text
stringlengths 595
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
=======================================================
Product ID: TF-33-7 FLOOR & STAIN MIX-RED
Cage: OEXY4
=======================================================
Contractor Summary
=======================================================
Cage: 0EXY4
Cage: OEXY4
Box: NA
=======================================================
Ingredients
=======================================================
Cas: 1309-48-4
RTECS #: OM3850000
% Wt: 27
OSHA PEL: 10 MG/M3 PARTICULATE
ACGIH TLV: 10 MG/M3, FUME
------------------------------
% Wt: 63
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHAL: MAY DEHYDRATE MUCOUS MEMBRANE. SKIN: MAY CAUSE
IRRITATION OF THE SKIN. EYES: MAY CAUSE IRRITATION OF THE EYES.
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES: FLUSH W/POTABLE WATER FOR AT LEAST 15 MINUTES. CALL MD(FP N).
SKIN: WASH DUST FROM SKIN W/MILD SOAP & WATER. INHAL: REMOVE TO FRESH
AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP)(FP N). INGEST: CAL L MD
IMMEDIATELY (FP N).
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: IF MATL IS NOT CONTAMD, PLACE INTO CLEAN CNTNRS FOR
USE. IF CONTAMD, PLACE INTO CNTNRS FOR DISPOSAL.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: CONSULT FEDERAL, STATE OR LOCAL AUTHORITIES FOR PROPER
DISPOSAL PROCEDURES. NON-BIODEGRADABLE SOLID WASTE SHOULD BE TAKEN TO A
LICENSED LANDFILL FACILITY.
Handling And Storage Precautions: STORE IN SPRINKLERED WAREHOUSE. KEEP
TEMPERATURES BELOW 140F(60C) FOR QUALITY.
Other Precautions: THIS PRODUCT MAY REACT WITH HOT OR CONCENTRATED NITRIC &
PERCHLORIC ACIDS, FUMING SULFURIC ACID AT 60C(140F) OR ABOVE AND SHOULD NOT
BE STORED NEAR SUCH MATERIALS.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: THIS MATERIAL IS NON-COMBUSTIBLE. USE MEDIA SUITABLE FOR
SURROUNDING FIRE.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT(FP N).
Unusual Fire/Explosion Hazard: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Control Measures
=======================================================
Respiratory Protection: ONLY NIOSH/MSHA APPROVED EQUIPMENT SHOULD BE USED.
Ventilation: PROVIDE ADEQUATE VENTILATION.
Other Protective Equipment: NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices: KEEP DUST & AIR CONCENTRATION TO MINIMUM. VACUUM TO
REMOVE COLLECTED DUST & PVNT FORMATION OF DUST CLOUDS. (SUPP DATA)
Supplemental Safety and Health: HYGIENE PRAC: AVOID INHALATION OF DUST &
CONTACT WITH EYES AND SKIN.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
Spec Gravity: 2.7-2.8(H*2O=1)
Solubility in Water: NEGLIGIBLE.
Appearance and Odor: RED SOLID, POWDER W/NO ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: AVOID DAMPNESS, HYDRATES MATERIALS, SOME
DECOMPOSITION OCCURS ABOVE 600C LIBERATING CO*2.
Materials To Avoid: STRONG ACIDS.
Hazardous Decomposition Products: NONE - COMBINATION WITH WATER GENERATES SOME
HEAT.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: TF-33-7 FLOOR & STAIN MIX-RED
Cage: OEXY4
Assigned IND: Y
Company Name: HILL BROTHERS CHEMICAL CO.
Street: 1675 NO. MAIN STREET
PO Box: NA
Zipcode: 92667
Label Required IND: Y
Date Of Label Review: 11/09/1994
Status Code: C
Label Date: 11/09/1994
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: Slight
Hazard And Precautions: ACUTE: INHAL: MAY DEHYDRATE MUCOUS MEMBRANE. SKIN: MAY
CAUSE IRRITATION OF THE SKIN. EYES: MAY CAUSE IRRITATION OF THE EYES.
CHRONIC: NONE SPECIFIED BY MANUFACTURER.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BROCO HIGH-STRENGTH FIBERED STUCCO
CAGE:SUTHD
CAGE:SUTHD
============= Composition/Information on Ingredients =============
Ingred Name:PORTLAND CEMENT
CAS:65997-15-1
RTECS #:VV8770000
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:TRICALCIUM SILICATE; (3*CAO-SIO*2) (CALCIUM SALT)
CAS:12168-85-3
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DICALCIUM SILICATE; (2*CAO-SIO*2) (CALCIUM SALT)
CAS:10034-77-2
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TRICALCIUM ALUMINATE; (3*CAO-AL*2O*3) (CALCIUM SALT)
CAS:12042-78-3
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TETRACALCIUM ALUMINOFERRATE; (4*CAO-AL*2O*3-FE*2O*3)
(CALCIUM SALT)
CAS:12068-35-8
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:GYPSUM; (CASO*4-2*H*2O) (CALCIUM SALT)
CAS:13397-24-5
RTECS #:MG2360000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:MAGNESIUM OXIDE (MGO)
CAS:1309-48-4
RTECS #:OM3850000
OSHA PEL:10 MG/M3 RESP
ACGIH TLV:10 MG/M3 FUME
Ingred Name:POTASSIUM SULFATE (2:1); (K*2SO*4)
CAS:7778-80-5
RTECS #:TT5900000
Fraction by Wt: TRACE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM SULFATE (2:1); (NA*2SO*4)
CAS:7757-82-6
RTECS #:WE1650000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:WET CEMENT, ESPECIALLY AS AN
INGREDIENT IN PLASTIC (UNHARDENED) CONCRETE, CAN DRY SKIN & CAUSE
ALKALI BURNS. CEMENT DUST CAN IRRITATE EYES & UPPER RESPIRATORY
SYSTEM. CHRONIC:CEMENT DUST CAN CAU SE INFLAMMATION OF LINING
TISSUE OF EYE. HYPERSENSITIVE INDIVIDUALS MAY DEVELOP AN ALLERGIC
DERMATITIS (SKIN RASH).
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . EYES:IRRIGATE W/WATER FOR
AT LEAST 15 MINUTES; CONSULT MD. SKIN:WASH EXPOSED AREAS W/SOAP &
WATER.
===================== Fire Fighting Measures =====================
Flash Point:NON COMBUSTIBLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:USE DRY CLEANUP METHODS THAT DO NOT DISPERSE
DUST INTO AIR.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PRECAUTIONS MUST BE OBSERVED BECAUSE
WET CEMENT BURNS W/LITTLE WARNING - LITTLE HEAT IS SENSED.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN DUSTY ENVIRONMENTS, USE A NIOSH/MSHA APPROVED
RESPIRATOR.
Ventilation:USE EXHAUST FANS TO CONTROL AIRBORNE DUST LEVELS.
Other Protective Equipment:ANSI APVD EMERGENCY EYE WASH & DELUGE SHOWER
. USE BARRIER CREAMS, BOOTS & CLOTHING TO PROTECT SKIN FROM
(SUPDAT)
Work Hygienic Practices:IMMEDIATELY AFTER WORKING W/CEMENT, WORKERS
SHOULD SHOWER W/SOAP & WATER.
Supplemental Safety and Health
OTHER PROT EQUIP: PROLONGED CONTACT W/WET CEMENT, ESPECIALLY IN PLASTIC
(UNHARDENED) CONCRETE.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:2.85-3.2
Solubility in Water:SLIGHT (0.1-1%)
Appearance and Odor:GRAY OR WHITE POWDER; NO ODOR.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:KEEP DRY UNTIL USED.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . MATERIAL CAN BE RETURNED TO CONTAINER FOR LATER USE,
OR IT CAN BE DISPOSED OF AS A COMMON WASTE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LEMON GO-JO WITH PUMICE HAND CLEANER, 0915
Preparer's Name:RONALD A. WILLIAMS
CAGE:02905
CAGE:02905
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA PETROLEUM, HEAVY ALKYLATE C-9-C12; (ISOPARAFFIN)
CAS:64741-65-7
Fraction by Wt: 30-60%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:WHITE MINERAL OIL; (MINERAL OIL)
CAS:8042-47-5
Fraction by Wt: 7-13%
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:GLYCOLS, POLYETHYLENE (NONYLPHENYL) ETHER (NONIONIC);
(NONIONIC SURFACTANT)
CAS:9016-45-9
RTECS #:MD0905000
Fraction by Wt: 5-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PUMICE; (SCRUBBING PARTICLES)
CAS:1332-09-8
Fraction by Wt: 5-10%
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:1,2-PROPANEDIOL; (PROPYLENE GLYCOL)
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. INGESTION: INGESTION
OF SMALL QUANTITY IS USUALLY NONFATAL UNLESS ASPIRATION OCCURS.
ASPIRATION MAY LEAD TO CHEMICAL PNEUMONITIS WHICH IS CHARACTERIZED
BY PULMONARY EDEMA & HEMORRHAG E & MAY BE FATAL.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
OXYGEN/ARTIFICIAL RESPIRATION) . SKIN: NOT APPLICABLE . EYES: DO
NOT RUB EYES. FLUSH W/WATER FOR AT LEAST 15 MIN. IF IRRIT PERSISTS
CNTC T MD. INGEST: DO NOT INDUCE VOMIT. CONTAINS ISOPARAFFIN &
MINERAL OIL. IF VOMIT OCCURS, LOWER VICTIM'S HEAD BELOW KNEES TO
AVOID ASPIR. CNTCT MD/POISON CONTROL CENTER IMMED.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>125F,>52C
Extinguishing Media:WATER FOG, ALCOHOL FOAM, CARBON DIOXIDE, DRY
CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB & COLLECT FOR DISPOSAL. FLUSH AREA WITH
WATER TO REDUCE POSSIBLE SLIPPERY FLOOR HAZARD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID EYE CONTACT. STORE AT AMBIENT
CONDITIONS.
Other Precautions:KEEP OUT OF REACH OF CHILDREN!
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NONE REQUIRED.
Ventilation:NONE REQUIRED.
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:ROUTINE.
Supplemental Safety and Health
PH: 8.5-9.5.
================== Physical/Chemical Properties ==================
Spec Gravity:0.88 (H*2O=1)
pH:SUPDAT
Solubility in Water:45%
Appearance and Odor:GREEN OPAQUE GEL; PLEASANT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:ACCORDING TO ALL LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CEILCOTE HARDENER 3R, 58711
CAGE:FO873
CAGE:98898
CAGE:FO873
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTANONE, PEROXIDE; (METHYL ETHYL KETONE PEROXIDE
STRUCTURES ACCOUNT FOR 8.8 9.1% ACTIVE OXYGEN (MEKP)) (CERCLA)
CAS:1338-23-4
RTECS #:EL9450000
Fraction by Wt: <40%
OSHA PEL:C 0.7 PPM
ACGIH TLV:C 0.2 PPM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:PHTHALIC ACID, DIMETHYL ESTER; (DIMETHYL PHTHALATE) (SARA
313) (CERCLA)
CAS:131-11-3
RTECS #:TI1575000
Fraction by Wt: 30-50%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2,4-PENTANEDIOL, 2-METHYL-; (HEXYLENE GLYCOL)
CAS:107-41-5
RTECS #:SA0810000
Fraction by Wt: 5-10%
OSHA PEL:C 25 PPM
ACGIH TLV:C 25 PPM
Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE) (MEK) (SARA 313) (CERCLA)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 1-5%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM/300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:HYDROGEN PEROXIDE (SARA 302)
CAS:7722-84-1
RTECS #:MX0900000
Fraction by Wt: <1%
OSHA PEL:1 PPM
ACGIH TLV:1 PPM
Ingred Name:SUPDAT: TO PREVENT ASPIRATION OF LIQUIDS INTO LUNGS. DO NOT
GIVE ANYTHING BY MOUTH TO UNCONSCIOUS PERSON.
RTECS #:9999999ZZ
Ingred Name:RESP PROT: OSHA REGULATION CFR 29 1910.134 FOR RECOMMENDED
RESPIRATORY PROTECTION.
RTECS #:9999999ZZ
Ingred Name:VENT: HEAVY VAPORS.
RTECS #:9999999ZZ
Ingred Name:EYE PROT: & FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL,RAT) 484 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: VAPORS CAN BE IRRITATING TO
NOSE, MUCOUS MEMBRANES, THROAT & UPPER RESPIRATORY TRACT. EYES:
CONTACT IS EXTREMELY IRRITATING & CORROSIVE. THIS MATL CAN CAUSE
DAMAGE OR BLINDNESS. SKIN CONT: SHOR T SINGLE EXPOS MAY CAUSE
MODERATE IRRITATION TO MILD BURN. PROLONGED/REPEATED EXPOSURE MAY
CAUSE SEVERE(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: BURN. SKIN ABSORP: LOW TOXICITY.
INGEST: CAN RESULT IN BURNS OF MOUTH, ESOPHAGUS & STOMACH. CHRONIC:
PRODUCT DOES NOT CNTN CARCIN MATLS AS DEFINED BY OSHA HAZ
COMMUNICATION ACT 1910.1200. AM ES TEST: MUTAGENIC IN SOME STRAINS
OF SALMONELLA. DIMETHYL PHTHALATE: EXPERIMENTAL TERATOGEN;
EXPERIMENTAL REPROD EFTS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM EXPOS. IF DFCLTY W/BRTHG, ADMIN OXYG. IF
BRTHG HAS STOPPED ADMIN ARTF RESP, PREF MOUTH-TO-MOUTH. SEEK MED
ATTN. EYES: FLUSH W/WATER, LIFTING UPPER & LOWER LIDS OCCASNLY FOR
@ LST 15 MINS. SEEK MED ATTN. SKIN: REMOVE CONTAMD CLTHG. WASH
THORO W/SOAP & WATER. IF IRRIT PERSISTS SEEK MED ATTN. WASH CONTAMD
CLTHG BEFORE REUSE. INGEST: DO NOT INDUCE VOMIT; GIVE LG QTYS OF
(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:137F,58C
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL & WATER FOG.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . USE WATER TO COOL CONTAINERS EXPOSED TO FIRE.
ELECTRICAL GROUNDING IS NOT RECOMMENDED.
Unusual Fire/Explosion Hazard:AT HIGHER TEMPERATURE VAPORS CAN CAUSE
PRESSURE BUILD UP IN SEALED CONTAINERS.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. ELIMINATE ALL SOURCES OF
IGNITION. WEAR APPROP PROTECTIVE GEAR, CONTAIN LEAK/SPILL, SALVAGE,
CLEAN UP RESIDUE W/NONCOMBUSTIBLE, NON-ACIDIC ABSORBENT MATERIAL
LIKE SAND OR SODA ASH. WAS H DOWN AREA WITH DETERGENT & WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR RESP PROT WHENEVER AIRBORNE CONCS EXCEED
TLV CEILINGS/TWA, USE NIOSH APPRVD RESPS EQUIPPED W/ORG VAP
CARTRIDGE FOR LISTED HAZ. CONFINED SPACES, ROOMS/TANKS ARE AREAS
WHERE CONCERN FOR TLV'S IS EX PECIALLY IMPORTANT. REFERENCE (ING 7)
Ventilation:VENT IS REC. AIR MOVEMENT MUST BE DESIGNED TO INSURE
TURNOVER @ ALL LOCATIONS IN WORK AREA TO AVOID BUILD UP OF (ING 8)
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
SELECTION OF SPECIFIC ITEMS SUCH AS BOOTS & APRON WILL DEPEND ON
OPERATION.
Work Hygienic Practices:DO NOT WEAR CONTACT LENSES WHEN WORKING WITH
THIS MATERIAL.
Supplemental Safety and Health
CNDTNS TO AVOID: BUILDUP & CNTNR FAILURE/EXPLO. EXCESS HEAT, FUMES &
SMOKE CAN OCCUR IF PROD IS NOT MIXED & USED ACCORDING TO
DIRECTIONS. NOT SENSITIVE TO MECH IMPACT. HAZ DECOMP PROD:
HYDROCARBONS FR OM INCOMPLETE COMBUST. FIRST AID PROC: WATER; GET
IMMED MED ATTN. IF VOMIT OCCURS SPONT, KEEP HEAD BELOW HIPS (ING 6)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:DECOMPOSES
Vapor Density:> AIR
Spec Gravity:1.07
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:NONE
Appearance and Odor:CLEAR OR RED LIQUID. SHARP AROMATIC ODOR.
Percent Volatiles by Volume:20
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING & REDUCING AGENTS, ACID, ISOCYANATES, ORGANIC COBALTS AMINES
METAL SALTS MAY RSLT IN VIOLENT EXPLOSIVE RXN.
Stability Condition to Avoid:AVOID TEMPS >140F AND/OR CONTAM. HIGHER
TEMPS AND/OR CONTAM PROMOTES EXOTHERMIC DECOMP POSSIBLY LEADING TO
PRESS(SUPDAT)
Hazardous Decomposition Products:DENSE SMOKE & INTENSE HEAT. OXIDES OF
CARBON & NITROGEN; KETONES, ALCOHOLS, METHANE, ETHANE, PHENOLS, &
VARIOUS (SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:HANDLE DISP OF WASTE MATL IN MANNER WHICH
COMPLIES WITH LOCAL, STATE, PROVINCE & FEDERAL REG. INCINERATE @
AGENCY APPRVD WASTE-DISP FACILITIES. PROD IS LISTED AS HAZ WAS REG.
CFR 261.33(F) AS U160. EM PTY CNTNRS SHOULD BE THORO WASHED BEFORE
DISP.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:B6107-3
CAGE:BAXT1
CAGE:BAXT1
CAGE:17749
============= Composition/Information on Ingredients =============
Ingred Name:PHOSPHOTUNGSTIC ACID
CAS:12067-99-1
Fraction by Wt: 1.9%
Ingred Name:NON HAZARDOUS INGREDIENTS
Fraction by Wt: 98.1%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE IRRITATION TO SKIN, EYES,
MUCOUS MEMBRANES.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:MAY CAUSE IRRITATION TO SKIN, EYES, MUCOUS
MEMBRANES.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMEDIATELY W/WATER/NORMAL SALINE FOR 15-20 MINS.
SKIN: WASH W/SOAP & WATER UNTIL NO EVIDENCE OF CHEMICAL REMAINS.
INGESTION: GIVE MILK/MILK OF MAGNESIA & WATER. IF VOMITING OCCURS,
KEEP H EAD BELOW HIPS TO PREVENT ASPIRATION. TREAT SYMPTOMATICALLY.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE AGENT SUITABLE FOR TYPE OF SURROUNDING FIRE.
Fire Fighting Procedures:AVOID BREATHING HAZARDOUS VAPORS, KEEP UPWIND.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:MOP W/WATER & DISPOSE INTO SANITARY SEWER/
SANITARY LANDFILL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED
Ventilation:LOCAL EXHAUST
Other Protective Equipment:LAB COAT
Work Hygienic Practices:USE GOOD LABORATORY PRACTICES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR COLORLESS SOLUTION
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE INTO SANITARY SEWER/SANITARY LANDFILL
IAW/ FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ADHESIVE 7069
Preparer's Name:BILL MCDONALD
CAGE:0FSN9
CAGE:0FSN9
============= Composition/Information on Ingredients =============
Ingred Name:PHENOL, POLYMER WITH FORMALDEHYDE, GLYCIDYL ETHER *97-2*
CAS:28064-14-4
Fraction by Wt: 10-20%
Ingred Name:REACTION PRODUCTS OF EPICHLOROHYDRIN & BISPHENOL A
*97-2*
CAS:25085-99-8
Fraction by Wt: 70-80%
Ingred Name:REFRACTORIES FIBERS, ALUMINOSILICATE
CAS:142844-00-6
Fraction by Wt: 0-5%
Ingred Name:AMORPHOUS FUMED SILICA, COLLOIDAL SILICON DIOXIDE,
AMORPHOUS SILICA DUST (IARC - GROUP 3) *97-2*
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 0-10%
Other REC Limits:20 MPPCF DUST IN AIR
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RATS): >5000 MG/KG
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: REPEATED EXPOSURE MAY CAUSE
IRRITATION/ALLERGIC REACTION. EYES: SLIGHT TRANSIENT TEMPORARY
IRRITATION. INGESTION: LOW SINGLE DOSE TOXICITY. SKIN
SENSITIZATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH FOR 15 MINS W/COPIOUS AMOUNTS OF WATER. SKIN:
IMMEDIATELY FLUSH W/PLENTY OF WATER FOR 15 MINS. INHALATION: REMOVE
TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN ALL CASES. NOTE TO
PHYSICIAN: NO SPECIFIC ANTIDOTE. SUPPORTIVE CARE. TREATMENT BASED
ON JUDGEMENT OF THE PHYSICIAN IN RESPONSE TO REACTIONS OF THE
PATIENT.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>424F
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS,
PRESSURE-DEMAND MSHA/NIOSH APPROVED & FULL FIRE PROTECTIVE
CLOTHING/GEAR.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP IN ABSORBENT SUCH AS SAND & COLLECT IN
SUITABLE CONTAINERS. RESIDUAL RESIN MAY BE REMOVED USING STEAM/HOT
SOAPY WATER. SOLVENTS ARE NOT RECOMMENDED FOR CLEANUP UNLESS
RECOMMENDED EXPOSURE GUID ELINES & SAFE HANDLING PRACTICES ARE
FOLLOWED.
======================Handling and Storage ======================
Other Precautions:PRACTICE GOOD CAUTION & PERSONAL CLEANLINESS TO AVOID
CONTACT W/SKIN/EYES. AVOID BREATHING VAPORS OF HEATED MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF HANDLING AT ELEVATED TEMPS W/O SUFFICIENT
VENTILATION, USE AN APPROVED, FULL FACE AIR PURIFYING RESPIRATOR.
Ventilation:USE ONLY W/ADEQUATE VENTILATION, LOCAL EXHAUST MAY BE
NECESSARY FOR SOME OPERATIONS.
Other Protective Equipment:FACESHIELD, FULL FACE RESPIRATOR, BODY
COVERING/CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:NONE
Appearance and Odor:GRAY, VISCOUS LIQUID W/FAINT EPOXY ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AMINES, BASES, ACIDS, OXIDIZING MATERIALS
Stability Condition to Avoid:EXCESS HEATING OVER LONG PERIODS OF TIME
DEGRADES THE RESIN.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION/PYROLYSIS OF
EPOXY RESINS: PHENOLICS, CO & WATER.
Conditions to Avoid Polymerization:QUANTITIES OF MORE THAN 1 POUND OF
PRODUCT PLUS AN ALIPHATIC AMINE WILL CAUSE IRREVERSIBLE
POLYMERIZATION W/HEAT BUILDUP
==================== Disposal Considerations ====================
Waste Disposal Methods:RESINS CAN BE DISPOSED OF BY
INCINERATION/LANDFILL IAW/LOCAL, STATE & FEDERAL REGULATIONS. DON'T
DUMP INTO ANY SEWERS, ON THE GROUND/INTO ANY BODY OF WATER.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:INDIAN HEAD GASKET SHELLAC
Preparer's Name:STEPHEN REPETTO
CAGE:62377
CAGE:62377
============= Composition/Information on Ingredients =============
Ingred Name:ROSIN
CAS:8050-09-7
Fraction by Wt: 55-60%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ISOPROPYL ALCOHOL (SARA 313)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 35-40%
Other REC Limits:500PPMPEL/TLV
OSHA PEL:400 PPM/500STEL
ACGIH TLV:400 PPM/500STEL
Ingred Name:VEGETABLE OIL
Fraction by Wt: 3/5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15MG/M3TDUST/RESP 5
ACGIH TLV:10 MG/M3 MISTS
Ingred Name:VOC = 34.8%
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT EST.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Effects of Overexposure:VAPOR ABOVE TLV IRRIT TO EYES NOSE THROAT, CAN
CAUSE DIZZINESS HEADACHE NAUSEA MODERATELY TOXIC BY INGESTION. EYE
IRRIT.
Medical Cond Aggravated by Exposure:SKIN EYE RESPIRATORY DISORDERS.
======================= First Aid Measures =======================
First Aid:INGEST INDUCE VOMITING CALL DR. INHAL GET FRESH AIR. IF
SYMPTOMS PERSIS CALL DR. SKIN: WASH W/SOAP & WATER. EYES: FLUSH
>15MIN W/WATER CALL DR.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:50.0F,10.0C
Lower Limits:2.3
Upper Limits:12.7
Extinguishing Media:CARBON DIOXIDE FOAM, DRY CHEM.
Fire Fighting Procedures:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION. MAINTAIN ADEQUATE
VENTILATION SCRAPE UP AS MUCH AS POSSIBLE STORE IN CLOSED CONTAINER
UNTIL DISPOSAL. RESIDUES MAY BE CLEANED WITH ISOPROPYL ALCOHOL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HEAT & FLAMES. AVOID
PROLONGED BREATHING OF VAPORS. KEEP AWAY FROM EYES.
============= Exposure Controls/Personal Protection =============
Ventilation:MUST BE ADEQUATE TO AVOID EXCEEDING TLV
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:180F,82C
Vapor Pres:33
Vapor Density:2.07
Spec Gravity:1.1
pH:NA
Evaporation Rate & Reference:NA
Solubility in Water:PARTIAL.
Appearance and Odor:BROWN VISCOUS TACKY LIQ W/ALCOHOLIC ODOR.
Percent Volatiles by Volume:34.8
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Hazardous Decomposition Products:THERMO DECOMP. IRRIT ORGANIC VAPORS.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE FOLLOWING EPA & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SB07736M, METHYL ORANGE POWDER
Resp. Party Other MSDS Num.:MM 465
Preparer's Name:MICHAEL RASZEJA
CAGE:6V042
CAGE:6V042
Contract Num:MDA414-01-P-0615
CAGE:33089
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ORANGE, PH INDICATOR
CAS:547-58-0
RTECS #:DB6327000
= Wt:93.
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NO DATA PROVIDED BY MANUFACTURER
Health Hazards Acute and Chronic:MAY BE HARMFUL BY INHALATION,
INGESTION, OR SKIN ABSORPTION. TO THE BEST OF OUR KNOWLEDGE, THE
CHEMICAL, PHYSICAL AND TOXICOLOGICAL PROPERTIES HAVE NOT BEEN
THOROUGHLY INVESTIGATED. SPECIFIC DATA IS N OT AVAILABLE. EXERCISE
APPROPRIATE PROCEDURES TO MINIMIZE POTENTIAL HAZARDS.
Explanation of Carcinogenicity:NO DATA PROVIDED BY MANUFACTURER.
Effects of Overexposure:MAY BE HARMFUL BY INHALATION, INGESTION, OR
SKIN ABSORPTION. TO THE BEST OF OUR KNOWLEDGE, THE CHEMICAL,
PHYSICAL AND TOXICOLOGICAL PROPERTIES HAVE NOT BEEN THOROUGHLY
INVESTIGATED. SPECIFIC DATA IS N OT AVAILABLE. EXERCISE APPROPRIATE
PROCEDURES TO MINIMIZE POTENTIAL HAZARDS.
Medical Cond Aggravated by Exposure:NO DATA PROVIDED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH THOROUGHLY WITH WATER FOR AT LEAST 15 MINUTES,
LIFTING UPPER AND LOWER EYELIDS OCCASIONALLY. IF IRRITATION
DEVELOPS, GET MEDICAL ATTENTION. SKIN: FLUSH THOROUGHLY WITH WATER,
THEN WASH WIT H MILD SOAP AND WATER. INGESTION: IF SWALLOWED, IF
CONSCIOUS, GIVE ONE OR TWO GLASSES OF WATER TO DRINK AND INDUCE
VOMITING. GET MEDICAL ATTENTION. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSO N. INHALATION: REMOVE TO FRESH AIR. IF ILL
EFFECTS DEVELOP, GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NON-VOLATILE SOL
Extinguishing Media:WATER SPRAY; CARBON DIOXIDE (CO2); DRY CHEMICAL
(ABC).
Fire Fighting Procedures:IN FIRE CONDITIONS, WEAR A NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS AND PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:WHEN HEATED TO DECOMPOSITION, EMITS TOXIC
FUMES OF OXIDES OF NITROGEN (NOX) AND SULFUR (SOX); CAN REACT
VIGOROUSLY WITH OXIDIZING MATERIALS.
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER FOR USE IF NOT CONTAMINATED. WEARING
SUITABLE PROTECTIVE CLOTHING, CAREFULLY SWEEP MATERIAL ONTO PAPER,
AVOID MAKING DUST. PLACE IN FIBER CARTON AND INCINERATE. WASH SPILL
AREA WELL WITH SOAP AND WATER.
Neutralizing Agent:NO DATA PROVIDED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE AWAY FROM
OXIDIZING MATERIALS. WASH THOROUGHLY AFTER HANDLING. KEEP CONTAINER
TIGHTLY CLOSED WHEN NOT IN USE.
Other Precautions:READ LABEL ON CONTAINER BEFORE USING. DO NOT WEAR
CONTACT LENSES WHEN WORKING WITH CHEMICALS. USE WITH ADEQUATE
VENTILATION. AVOID DUST GENERATION. REMOVE AND WASH CONTAMINATED
CLOTHING. FOR LABORATOR Y USE ONLY. NOT FOR DRUG, FOOD OR HOUSEHOLD
USE. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NEEDED IN NORMAL LABORATORY HANDLING. IF
DUSTY CONDITIONS PREVAIL, WORK IN VENTILATION HOOD OR WEAR A
NIOSH-APPROVED DUST MASK OR RESPIRATOR.
Ventilation:LOCAL EXHAUST: RECOMMENDED; MECHANICAL(GENERAL):
RECOMMENDED
Other Protective Equipment:SMOCK, APRON, EYE WASH STATION, PROPER
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NOTE FROM DLA-HMIS STAFF: HCC OF T6 ASSIGNED DUE TO VERBAGE IN
ACUTE/CHRONIC/EFFECTS.
================== Physical/Chemical Properties ==================
HCC:T6
Boiling Pt:B.P. Text:DECOMPOSES
Melt/Freeze Pt:M.P/F.P Text:DECOMPOSES
Vapor Pres:NEGLIGIBLE
Vapor Density:11.3
Spec Gravity:APPROX. 1.0
Solubility in Water:0.2 GRAMS PER 100 ML. WAT
Appearance and Odor:BROWN-ORANGE CRYSTALLINE POWDER; NO ODOR
Percent Volatiles by Volume:NEGLIGIBLE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS AND REDUCING AGENT.
Stability Condition to Avoid:PROTECT FROM LIGHT. EXCESSIVE TEMPERATURE
OR HEAT.
Hazardous Decomposition Products:THERMAL DECOMPOSITION OR BURNING MAY
PRODUCE CARBON DIOXIDE AND/OR CARBON MONOXIDE, NOX, SOX.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:NO DATA PROVIDED BY MANUFACTURER.
===================== Ecological Information =====================
Ecological:NO DATA PROVIDED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE OR LOCAL LAWS. THESE DISPOSAL GUIDELINES ARE
INTENDED FOR THE DISPOSAL OF CATALOG-SIZE QUANTITIES ONLY. DISPOSE
OF IN AN APPROVED INC INERATOR EQUIPPED WITH AN AFTERBURNER AND
SCRUBBER OR CONTRACT WITH A LICENSED WASTE DISPOSAL SYSTEM .
=================== MSDS Transport Information ===================
Transport Information:NON-REGULATED.
===================== Regulatory Information =====================
SARA Title III Information:NO DATA PROVIDED BY MANUFACTURER.
Federal Regulatory Information:NO DATA PROVIDED BY MANUFACTURER.
State Regulatory Information:NO DATA PROVIDED BY MANUFACTURER.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: EF PRIMER 49
Cage: DO346
=======================================================
Contractor Summary
=======================================================
Cage: 61603
Cage: DO346
=======================================================
Ingredients
=======================================================
Cas: 67-64-1
RTECS #: AL3150000
% Wt: 85-90
OSHA PEL: 1000 PPM
ACGIH TLV: 750PPM/1000STEL;9495
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 67-63-0
RTECS #: NT8050000
% Wt: 10-15
OSHA PEL: 400 PPM
ACGIH TLV: 400 PPM/500STEL;9495
------------------------------
% Wt: 1-3
OSHA PEL: 400 PPM
ACGIH TLV: 400 PPM/500STEL;9495
-----------------------------
Cas: 149-30-4
RTECS #: DL6475000
% Wt: 1-3
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: TOXICITY: POSSIBLE EYE AND RESPIRATORY IRRITANT. NARCOTIC
AT HIGH CONCENTRATION. PROLONGED INHALATION MAY CAUSE HEADACHES. MODERATELY
TOXIC BY INGESTION. LIQUID MAY DEFAT SKIN.
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: VAPORS IRRITATE EYES, NOSE AND THROAT.
LIQUID IS AN EYE IRRITANT AND MAY IRRITATE SKIN.
Medical Cond Aggravated By Exposure: NONE KNOWN.
First Aid: INGESTION: DO NOT INDUCE VOMITING. KEEP INDIVIDUAL CALM. OBTAIN
MEDICAL ATTENTION. INHALATION: REMOVE TO FRESH AIR. IF SYMPTOMS PERSIST,
OBTAIN MEDICAL ATTENTION. SKIN: WASH WITH SOAP AND WATER. EYE: FLUSH AT
LEAST 15 MINUTES WITH WATER. OBTAIN MEDICAL ATTENTION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: AVOID FLAME AND SPARKS. MAINTAIN ADEQUATE
VENTILATION. SOAK UP IN AN INERT ABSORBENT AND STORE IN A CLOSED CONTAINER
UNTIL DISPOSAL.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: INCINERATE FOLLOWING EPA AND LOCAL, STATE AND FEDERAL
REGULATIONS.
Handling And Storage Precautions: STORE BELOW 82F TO PRESERVE SHELF LIFE. STORE
AWAY FROM FLAME AND SPARKS. AVOID PROLONGED BREATHING OF FUMES. AVOID SKIN OR
EYE CONTACT.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: 17.0F,-8.3C
Lower Limits: SEE INGRED
Upper Limits: SEE INGRED
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF
CONCERN (FP N).
Ventilation: SUFFICIENT TO MAINTAIN VAPOR CONCENTRATION BELOW TLV.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: VP: 230 MILLIBARS @ 68F.
=======================================================
Physical/Chemical Properties
=======================================================
Vapor Pres: SUPDAT
Spec Gravity: 0.791
VOC Grams/Liter: 775
Evaporation Rate & Reference: NOT KNOWN
Solubility in Water: MISCIBLE
Appearance and Odor: CLEAR, AMBER LIQUID; ACETONE ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: STRONG OXIDIZERS, PEROXIDES.
Hazardous Decomposition Products: HAZARDOUS PRODUCTS FORMED BY FIRE/THERMAL
DECOMPOSITION: IRRITATING ORGANIC VAPORS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: VOC (EPA METHOD 24): 97.96%; 775 G/L.
=======================================================
HAZCOM Label
=======================================================
Product ID: EF PRIMER 49
Cage: DO346
Assigned IND: Y
Company Name: HERNON MANUFACTURING INC.
Street: 865 ESSEX STREET
Zipcode: 11208-5220
Label Required IND: Y
Date Of Label Review: 09/17/1996
Status Code: C
Label Date: 09/17/1996
Origination Code: G
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE LIQUID. ACUTE: VAPORS IRRITATE EYES, NOSE AND
THROAT. LIQUID IS AN EYE IRRITATION AND MAY IRRITATE SKIN. TOXICITY: POSSIBLE
EYE AND RESPIRATORY IRRITANT. NARCOTIC AT HIGH CONCENTRATION. PROL ONGED
INHALATION MAY CAUSE HEADACHES. MODERATELY TOXIC BY INGESTION. LIQUID MAY
DEFAT SKIN. CHRONIC: NONE SPECIFIED BY MANUFACTURER.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TURCO SURJ
CAGE:D9808
CAGE:61102
CAGE:D9808
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM CARBONATE
CAS:497-19-8
RTECS #:VZ4050000
Fraction by Wt: 35%
Ingred Name:SODIUM TRIPOLYPHOSPHATE
RTECS #:YK4900000
Fraction by Wt: 10%
Ingred Name:DODECYL BENZENE SULFONIC ACID,SODIUM SALT
CAS:25155-30-0
RTECS #:DB6825000
Fraction by Wt: 1%
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 50%
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SODIUM NITRITE (SARA III)
CAS:7632-00-0
RTECS #:RA1225000
Fraction by Wt: 0.5%
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Effects of Overexposure:SKIN:IRRIT.EYE:CORNEAL DAMAGE,BLINDNESS.VAPOR:
IRRIT RESP TRACT.INGESTION: TISSUE DAMAGE.
======================= First Aid Measures =======================
First Aid:SKIN:FLUSH WITH WATER,REMOVE & LAUNDERED BEFORE REUSE.EYE:
FLUSH WITH WATER 15 MIN,CALL A PHYSICIAN IMMED.INHALATION:REMOVE TO
FRESH AIR,CALL A MD.INGESTION:GIVE LARGE QUANTITY OF MILK OR
WATER.CALL A MD. DO NOT INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Unusual Fire/Explosion Hazard:CONTACT WITH ALUMINUM OR OTHER REACTIVE
METALS MAY GENERATE HYDROGEN GAS IN EXPLOSIVE AMOUNTS
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP SPILLAGE AND RETURN TO CONTAINER.SOAK
UP SPILLS OF WATER SOLUTION WITH SWEEPING COMPOUND OR ABSORBENT
MATERIAL AND PLACE IN SEALABLE CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:TRANSPORT & STORE IN CLOSED CONTAINERS
AT TEMPERATURES BELOW 130F/54C,ADD CAUTIOUSLY TO COOL WATER,WITH
AGITATION: HEAT EVOLVED
Other Precautions:HAZARDOUS CARBON MONOXIDE GAS CAN FORM UPON CONTACT
WITH FOOD & BEVERAGE PRODUCTS IN ENCLOSED SPACES.FOLLOW APPROPRIATE
TANK ENTRY PROCEDURES (SEE ANSI Z117.1-1977 OR CURRENT UPDATE
CHANGE)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN.
Ventilation:GENERAL MECHANICAL
Supplemental Safety and Health
ADD INGRED: NONIONIC WETTING AGENT,2%;SODIUM GLUCONATE,2%.
================== Physical/Chemical Properties ==================
Vapor Pres:<1
Solubility in Water:APPRECIABLE
Appearance and Odor:TAN GRANULAR MIX
Percent Volatiles by Volume:<1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS,ALUMINUM,TIN,ZINC
Hazardous Decomposition Products:HEAT,STEAM (HYDROGEN,WHEN IN CONTACT
WITH REACTIVE METALS)
==================== Disposal Considerations ====================
Waste Disposal Methods:NEUTRALIZE ALKALINITY AND SEPARATE FLOATABLE
GREASES AND OILS FOR INCINERATION OR DISPOSAL IN LANDFILL.DISCHARGE
NEUTRALIZED WATER LAYER IN ACCORDANCE WITH FEDERAL,STATE AND LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:7200-06, 5020/7020 DEVELOPER-SAVIN
Preparer's Name:KRISTINA SAGE
CAGE:54726
CAGE:54726
============= Composition/Information on Ingredients =============
Ingred Name:NICKEL (II) OXIDE (1:1); (FERRITE POWDER) PEL/TLV AS NI
CAS:1313-99-1
RTECS #:QR8400000
Fraction by Wt: < 97.0%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:ZINC OXIDE; (FERRIC POWDER)
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: < 97.0%
OSHA PEL:15MG/M3 TDUST/5 FUME
ACGIH TLV:10MG/M3 TDUST; 9293
Ingred Name:COPPER OXIDE; (FERRITE POWDER). PEL/TLV AS CU
CAS:1317-38-0
RTECS #:GL7900000
Fraction by Wt: < 97.0%
OSHA PEL:1MG/M3 DUST;0.1 FUME
ACGIH TLV:1MG/M3 DUST;0.2 FUME
Ingred Name:HEMATITE; (FERRITE POWDER) PEL/TLV AS FE
CAS:1317-60-8
RTECS #:MH7600000
Fraction by Wt: < 97.0%
OSHA PEL:10 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:STYRENE, ACRYLATE COPOLYMER; (STYRENE ACRYLIC POLYMER)
CAS:25213-39-2
Fraction by Wt: < 03.0%
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: < 03.0%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:DYE
CAS:84170-66-8
Fraction by Wt: < 03.0%
Ingred Name:DYE
CAS:109125-50-0
Fraction by Wt: < 03.0%
Ingred Name:DYE
CAS:109125-51-1
Fraction by Wt: <03.0%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: MAY CAUSE TEMPORARY EYE
DISCOMFORT. SKIN: MAY CAUSE SLIGHT IRRITATION ON PROLONGED AND
REPEATED CONTACT WITH SKIN. INHAL: GASPING. INGEST: GREATER THAN 5
G/KG BODYWEIGHT, PRACTICALLY NON- TOXIC. CHRONIC: NOT APPLICABLE.
Explanation of Carcinogenicity:NICKEL AND NICKEL COMPOUNDS: GROUP 1
(IARC), GROUP 2 (NTP).
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:EYES: TRY TO REMOVE OR FLUSH WITH EYE DROPS FOR AT LEAST 15
MIN. IF UNSUCCESSFUL, GET MEDICAL ATTN. SKIN: WASH THOROUGHLY WITH
SOAP AND WATER. INHAL: REMOVE FROM EXPOSURE. INGEST: DILUTE STOMACH
CONTE NTS WITH SEVERAL GLASSES OF WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, DRY CHEMICALS, FOAM OR WATER.
Fire Fighting Procedures:NO SPECIAL FIRE-FIGHTING PROCEDURE IS
NECESSARY. WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:WILL NOT OCCUR.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP USING AN APPRVD TONER VACUUM CLEANER
W/A 0.5 MICRON FILTER SUCH AS ATRIX AAA TONER VACUUM CLEANER. USE
OF A VACUUM CLEANER NOT RATED FOR TONER PARTICULATE COULD BE A
POTENTIAL FIRE HAZ &/OR R SLT IN PERSONAL INJURY. REMOVE RESIDUE
(SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CLEANSE SKIN THOROUGHLY AFTER CONTACT,
BEFORE BREAKS AND MEALS, AND AT THE END OF WORK PERIODS. KEEP OUT
OF REACH CHILDREN.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL CONDITIONS OF USE.
NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN
.
Ventilation:LOCAL EXHAUST: NONE REQUIRED UNDER NORMAL CONDITIONS OF
USE. MECHANICAL (GENERAL): ADEQUATE VENTILATION.
Other Protective Equipment:NONE REQUIRED UNDER NORMAL CONDITIONS OF
USE.
Work Hygienic Practices:CLEANSE SKIN THOROUGHLY AFTER CONTACT, BEFORE
BREAKS AND MEALS, AND AT THE END OF WORK PERIODS.
Supplemental Safety and Health
SPILL PROC: WITH SOAP AND WATER.
================== Physical/Chemical Properties ==================
HCC:T6
Melt/Freeze Pt:M.P/F.P Text:>176F,>80C
Spec Gravity:1.97
Solubility in Water:NEGLIGIBLE; <0.1%
Appearance and Odor:BLACK POWDER, WITH SLIGHT PLASTIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO AND OTHER DECOMPOSITION PRODUCTS IN
THE CASE OF COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:USED DEVELOPER SHOULD BE DISP OF IN AN ENVIRON
SAFE MANNER & I/A/W LOC, STATE & FED GOVTL REGS. DISP REGS VARY
FROM LOCALITY TO LOCALITY, THEREFORE, CONSULT W/YOUR LOC OFFICE OF
EPA TO DETERMINE PROPE R METH OF DISP. DO NOT INCINERATE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:P/N 5988 FINAL GLAZE
CAGE:52157
CAGE:52157
CAGE:050Q3
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 60-70%
Other REC Limits:NONE RECOMMENDED
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 10-20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9596
Ingred Name:SILICA GEL
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 1-10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:HYDROTREATED LIGHT NAPHTHENIC PETROLEUM DISTILLATES OR
MINERAL OIL
CAS:64742-53-6
RTECS #:PY8036000
Fraction by Wt: 1-10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:GLYCERIN (GLYCEROL)
CAS:56-81-5
RTECS #:MA8050000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 (MIST)
ACGIH TLV:10 MG/M3 (MIST);9596
Ingred Name:VOLATILE ORGANIC CONTENT: 198.00 GM/L, SAQMD, CALCULATED;
584.46 GM L, SAQMD, LESS H20/EXEMPT SOLVENTS
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EXPOSURE MAY CAUSE EYE, SKIN &
RESPIRATORY TRACT IRRITATION. INHALATION MAY CAUSE KIDNEY EFFECTS.
INGESTION MAY CAUSE GI TRACT IRRITATION. ASPIRATION MAY CAUSE
CHEMICAL PNEUMONITIS. CHRONIC: NO NE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:EYES-IRRITATION, REDNESS, SWELLING, PAIN,
TEARING, HAZY VISION. SKIN-IRRITATION, REDNESS, SWELLING, ITCHING.
INHALED-IRRITATION, SORENESS OF THROAT/NOSE, COUGHING, SNEEZING.
INGESTED-GI TRACT IRRITATI ON, PAIN, VOMITING, ABDOMINAL
TENDERNESS, NAUSEA, BLOOD IN VOMITUS, BLOOD IN FECES.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:IN ALL CASES GET MEDICAL ATTENTION. EYES-FLUSH WITH WATER FOR
15 MINUTES. SKIN-REMOVE CONTAMINATED CLOTHES. WASH WITH MILD SOAP &
WATER. INHALED-REMOVE TO FRESH AIR. ADMINISTER OXYGEN OR ARTIFICIAL
RE SPIRATION AS NEEDED. INGESTED-CONTACT POISON CONTROL CENTER AND
OBTAIN IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:115F,46C
Lower Limits:0.90
Upper Limits:6.00
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL FIRE FIGHTER'S PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:REFER TO OTHER MSDS SECTIONS FOR ADVICE ON
PHYSICAL & HEALTH HAZARDS, RESPIRATORY PROTECTION, VENTILATION, &
PERSONAL PROTECTIVE EQUIPMENT. CALL 612-733-1110/733-6100 FOR 24-HR
SPILL ASSISTANCE. COLLE CT SPILLED MATERIAL, PLACE IN CONTAINER&
SEAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. KEEP
OUT OF REACH OF CHILDREN. USE IN A WELL-VENTILATED AREA. AVOID SKIN
CONTACT. AVOID EYE CONTACT.
Other Precautions:KEEP AWAY FROM SOURCES OF IGNITION. DO NOT INGEST.
AVOID PROLONGED BREATHING OF PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID PROLONGED BREATHING OF VAPORS.
Ventilation:USE IN A WELL-VENTILATED AREA.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:212F,100C
Vapor Density:3.90
Spec Gravity:0.98
pH:5-5.4
Viscosity:1.4K-3.5K CPS
Evaporation Rate & Reference:4.40 (ETHER=1)
Solubility in Water:DILUTABLE
Appearance and Odor:TAN COLORED VISCOUS LIQUID; SWEET SOLVENT ODOR.
Percent Volatiles by Volume:82
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:MIX WITH FLAMMABLE MATERIAL AND INCINERATE IN A
PERMITTED HAZARDOUS WASTE FACILITY. DISPOSE OF COMPLETELY ABSORBED
WASTE PRODUCT IN A FACILITY TO ACCEPT CHEMICAL WASTES. USE EPA
HAZARDOUS WASTE NUMBER = D001 (IGNITABLE).
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:N801-0060 AMPLITAQ DNA POLYMERASE (250 UNITS)
CAGE:1Z582
CAGE:1Z582
============= Composition/Information on Ingredients =============
Ingred Name:GLYCERINE, 1,2,3,-TRIHYDROXYPROPANE, GLYCEROL, ANHYDROUS
GLYCERINE, GLYCERIN
CAS:56-81-5
RTECS #:MA8050000
Fraction by Wt: 50%
ACGIH TLV:10 MG/CUM (VAPOR)
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Ingred Name:1,3-PROPANEDIOL , 2-AMINO-2-(HYDROXYMETHYL)
CAS:77-86-1
RTECS #:TY2900000
Fraction by Wt: <1%
Ingred Name:POTASSIUM CHLORIDE
CAS:7447-40-7
RTECS #:TS8050000
Fraction by Wt: <1%
Ingred Name:ACETIC ACID (ETHYLENEDIAMINETETRAACETIC ACID), EDTA
CAS:60-00-4
RTECS #:AH4025000
Fraction by Wt: <1%
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:DITHIOTHREITOL *95-1*
CAS:3483-12-3
RTECS #:EK1610000
Fraction by Wt: <1%
Ingred Name:POLYSORBATE 20; SORBITAN, MONODODECANOTE; SORBITAN
MONOLAURATE
CAS:9005-64-5
RTECS #:TR7400000
Fraction by Wt: <1%
Ingred Name:TRITON X-100, OCTYLPHENOXYPOLYETHOXYETHANOL; TRITON X100
CAS:9036-19-5
RTECS #:RI0525000
Fraction by Wt: <1%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THE ONLY LIKELY SYMPTOM WOULD BE A
LOCAL REACTION SUCH AS REDDENING/INFLAMMATION, AFTER ACCIDENTAL
INJECTION OF THIS COMPOUND.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:THE ONLY LIKELY SYMPTOM WOULD BE A LOCAL
REACTION SUCH AS REDDENING/INFLAMMATION, AFTER ACCIDENTAL INJECTION
OF THIS COMPOUND.
======================= First Aid Measures =======================
First Aid:SKIN: FLUSH W/RUNNING WATER. EYES: FLUSH W/WATER FOR 15 MINS.
HAVE VICTIM ROLL EYES. INGESTION: IF PROFESSIONAL ADVICE ISN'T
AVAILABLE, INDUCE VOMITING. NEVER INDUCE VOMITING/GIVE DILUENTS
(MILK/WATER ) IF UNCONSCIOUS/HAVING CONVULSIONS/CAN'T SWALLOW.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:USE FIRE FIGHTING PROCEDURES FOR THE MATERIALS
IN THE VICINITY OF THIS PRODUCT.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
AREA W/SOAP & WATER, ABSORB W/PAPER TOWELS & RINSE W/WATER. PLACE
RESIDUE IN A DOUBLE PLA STIC BAG & SEAL.
======================Handling and Storage ======================
Handling and Storage Precautions:FOLLOW INSTRUCTIONS PROVIDED IN
PACKAGE. DON'T EAT/DRINK WHILE HANDLING CHEMICALS. USE W/ADEQUATE
VENTILATION.
Other Precautions:AVOID GETTING CHEMICALS ON YOU/IN YOU.
============= Exposure Controls/Personal Protection =============
Ventilation:REQUIRED
Other Protective Equipment:LAB COAT
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Melt/Freeze Pt:M.P/F.P Text:32F
Vapor Pres:AS WATER
Spec Gravity:1
Evaporation Rate & Reference:(WATER =1): 1
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID, LIKE WATER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MATERIALS WHICH ARE NOT COMPATIBLE W/SUBSTANCES WHICH ARE INCOMPATIBLE
W/WATER
Stability Condition to Avoid:ANY SET OF CONDITIONS WHICH SHOULD BE
AVOIDED FOR WATER.
==================== Disposal Considerations ====================
Waste Disposal Methods:IF CHEMICAL IS UNALTERED BY THE HANDLING, IT MAY
BE DISPOSED OF BY TREATMENT AT A PERMITTED FACILITY/DISPOSED OF IN
ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DOLPHON, CB-1131-B
Kit Part:Y
CAGE:GO805
CAGE:GO805
CAGE:72688
============= Composition/Information on Ingredients =============
Ingred Name:DIPHENYL METHANE DIISOCYANATE
CAS:26447-40-5
Fraction by Wt: 45-55%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:OLIGOMERS; (HIGHER OLIGOMERS)
Fraction by Wt: 45-55%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:INHALATION OF VAPS/MIST CAN
CAUSE IRRIT OF RESP TRACT, RSLTG IN RUNNY NOSE, SORE THROAT,
COUGHING, CHEST DISCOMFORT & SHORTNESS OF BREATH. EXPOS WELL ABOVE
TLV MAY LEAD TO BRONCH & PULM EDEMA. T HESE EFTS ARE USUALLY
REVERSIBLE. AS A RSLT OF A PREVIOUS RPTD OVEREXPOS OF SGL LGE DOSE,
CERTAIN (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:INDIV DEVELOP EITHER TEMPORARY OR PERM
ISOCYANATE SENSIT, W/SYMPS SUCH AS CHEST TIGHTNESS, WHEEZING,
COUGH, SHORTNESS OF BREATH OR ASTHMA ATTACK. OVEREXPOS MAY ALSO
CAUSE PERM LUNG DAM. EYE C ONT:CAN CAUSE TEARING, REDDENING &
SWELL. IF LEFT UNTREATED, CORNEAL DAM CAN OCCUR. SKIN CONT:CAN
CAUSE IRRIT (SUP DAT)
Medical Cond Aggravated by Exposure:ASTHMA, RESPIRATORY DISORDERS, SKIN
ALLERGIES & ECZEMA.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE VICTIM TO FRESH AIR. IF NOT BREATHING, BEGIN
ARTIFICIAL RESPIRATION. GET MEDICAL ATTENTION. EYES:FLUSH W/CLEAN
WATER FOR 20 MINS. GET MEDICAL ATTENTION. SKIN:WASH THOROUGHLY W/
SOAP & WAT ER. INGEST:DO NOT INDUCE VOMITING. GIVE250 ML OF MILK OR
WATER TO DRINK. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:390F,199C
Extinguishing Media:FOAM, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . USE COLD WATER TO COOL FIRE EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:DURING A FIRE, MDI VAPS & OTHER
IRRITATING, HIGHLY TOX GASES MAY BE GENERATED. AT TEMPS >400F,
POLYMERIC MDI CAN POLYMERIZE & DECOMPOSE WHICH CAN (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:EVAC & VENT SPILL AREA. WEAR PROT EQUIP. DIKE
SPILL TO PVNT ENTRY INTO WATER SYS. LGE QTYS MAY BE PUMPED INTO
CLSD BUT NOT SEALED CONTRS. SMALL:ABSORB W/ABSORBENT. SHOVEL INTO
UNSEALED CONTRS. NEUT W/ WATER, 3-8% AMMONIA, 2% DETERGENT. ALLOW
(SUP DAT)
Neutralizing Agent:WATER, 3-8% AMMONIA, 2% DETERGENT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN TIGHTLY CLOSED CONTAINERS TO
PREVENT MOISTURE CONTAMINATION, AWAY FROM HEAT.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR MUST
BE WORN DURING SPRAYING, LONG TERM EXPOSURES, WHEN PRODUCT IS
HEATED OR IN ENVIRONMENTS OF CONCENTRATIONS ABOVE THE TLV.
Ventilation:TO MAINTAIN THE EXPOSURE UNDER THE TLV.
Other Protective Equipment:PROTECTIVE CLOTHING, EYE WASH STATION &
SAFETY SHOWERS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
KEY1;T4.EXPLO HAZ:CAUSE PRESS BUILD UP IN CLSD CONTRS. EXPLOS RUPTURE
IS POSS. EFTS OF OVEREXP:W/SYMPS AS REDDENING, SWELLING, RASH,
SCALING OR BLISTERING. PRLNGD CONT CAN CAUSE SENSIT. INGEST:CAN RSL
T IN IRRIT & CORR ACTION IN MOUTH, STOMTISS & DIGESTIVE TRACT.
SPILL PROC:TO STAND UNCOVERED FOR 48 HRS TO LET CO2 ESCA
================== Physical/Chemical Properties ==================
HCC:T4
Boiling Pt:B.P. Text:406F,208C
Vapor Pres:LOW
Vapor Density:HVR/AIR
Spec Gravity:1.24
Evaporation Rate & Reference:NEGLIGIBLE
Solubility in Water:REACTS W/WATER
Appearance and Odor:DARK BROWN LIQUID W/PUNGENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, AMINES, STRONG BASES, ALCOHOL WILL CAUSE SOME CORROSION TO
COPPER ALLOYS & ALUMINUM.
Stability Condition to Avoid:WILL DECOMPOSE RAPIDLY ABOVE 400F.
Hazardous Decomposition Products:CARBON MONOXIDE, OXIDES OF NITROGEN,
TRACES OF HCN, MDI VAPORS.
Conditions to Avoid Polymerization:CONTACT W/WATER OR MATERIALS WHICH
REACT W/ ISOCYANATES. TEMPERATURES ABOVE 400F.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/APPLICABLE LOCAL,
STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ZYGLO EMULSIFIER ZR-10B
Resp. Party Other MSDS Num.:ZR-10B
Preparer's Name:CHERL A ZELEZNIK
CAGE:37676
CAGE:37676
CAGE:59042
============= Composition/Information on Ingredients =============
Ingred Name:POLY(OXY-1,2-ETHANEDYL),ALPHA(NONYLPHENYL)-OMEGA-HYDROXY
LD50 (ORAL, RAT): 2 G/KG
CAS:9016-45-9
RTECS #:MD0900000
Code:F
Minumum % Wt:60.
Maxumum % Wt:100.
Ingred Name:2-METHYL-2,4-PENTANEDIOL LD50(ORAL, GUINEA PIG): 2.8 G/KG
CAS:107-41-5
RTECS #:SA0810000
Minumum % Wt:30.
Maxumum % Wt:60.
OSHA PEL:25 PPM (CEILLING)
ACGIH TLV:25 PPM (CELLING
ACGIH STEL:C121 MG/M3;C25 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: CAN IRRITATE BY REMOVING NATURAL
SKIN OILS ON LONG OR REPEATED EXPOSURES. EYES: IRRITATING.
INHALATION: NOT SIGNIFICANT AT ROOM TEMPERATURE. WHEN HEATED OR
SPRAYED, ZR-10B VAPORS MAY CAUSE DIZZI NESS AND NAUSEA. INGESTION:
NOT SIGNIFICANT IN SMALL (MOUTHFUL) AMOUNTS.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:SKIN: WASH OFF WITH SOAP AND WATER. USE SOOTHING LOTION.
EYES: RINSE CAREFULLY UNDER UPPER & LOWER EYELIDS FOR AT LEAST 15
MINUTES USING PLENTY OF WATER. INHALATION: REMOVE TO FRESH AIR.
INGESTION: DO NOT INDUCE VOMITING. ACCIDENTAL INGESTION OF SMALL
MOUTHFUL IS NOT EXPECTED TO CAUSE SIGNIFICANT HARM. NOTE: IN ALL
OPERATORS CAN FURNISH NUMBER OF REGIONAL POISON CONTROL CENTER.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>93.3C, 200.F
Lower Limits:1%
Upper Limits:6%
Extinguishing Media:CARBON DIOXIDE, FOAM.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . KEEP CONTAINERS COOL WITH WATER SPRAY. IN USE, ZR-10B
IS DISSOLVED INTO WATER, NEARLY ELIMINATING ITS ABILITY TO BURN.
Unusual Fire/Explosion Hazard:CONDITIONS OF FLAMMABILITY: HEATING ABOVE
200F(93C) IN PRESENCE OF IGNITION SOURCES.
================== Accidental Release Measures ==================
Spill Release Procedures:MOP OR SWEEP UP WITH ABSORBANT.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING SPRAY MIST. AVOID EYE
CONTACT. AVOID REPEATED OR PROLONGED SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE, UNLESS APPLIED AS SPRAY. NIOSH APPROVED
RESPIRATOR WITH FILTER IF SPRAYED IN ENCLOSED UNVENTILATED SPACE.
Ventilation:NONE, UNLESS APPLIED AS SPRAY. USE WHERE VENTILATION WILL
CARRY SPRAY MIST AWAY FROM OCCUPIED AREAS.
Other Protective Equipment:EYE WASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA .
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:>196.1C, 385.F
B.P. Text:(ASTM D-86)
Vapor Pres:<0.10 MM @70F (21C)
Vapor Density:HVR/AIR
Spec Gravity:0.9
pH:NEUTRAL
Evaporation Rate & Reference:NEGLIGIBLE
Solubility in Water:100%
Appearance and Odor:PINK VISCOUS LIQUID. MILD ODOR.
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:SOOT, OXIDES OF CARBON IF HEATED TO
COMBUSTION TEMPERATURES.
=================== Toxicological Information===================
Toxicological Information:CARCINOGENICITY: CONTAINS NO KNOWN OR
SUSPECTED CARCINOGENS LISTED WITH OSHA, IARC, NTP, OR ACGIH.
THRESHOLD LIMIT VALUE: 5 MG/M3 FOR OILY MIST. WHMIS INFORMATION
(CANADA): ACCORDING TO AVAILABLE INFO RMATION, THE INGREDIENTS HAVE
NOT BEENFOUND TO SHOW REPRODUCTIVE TOXICITY, TERATOGENICITY,
MUTAGENICITY, SKIN SENSITIZATION, OR SYNERGISTIC TOXIC EFFECT WITH
OTHER MATERIALS.
===================== Ecological Information =====================
Ecological:NO DATA IS AVAILABLE ON ZR-10B. IT DISSOLVES INTO WATER AND
IS BIODEGRADABLE. ITS LOW VAPOR PRESSURE MAY EXEMPT IT FROM VOC
RESTRICTIONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:AS NON-HAZARDOUS OILY WASTE, INCINERATE OR SEND
TO WASTE HANDLER WHO CAN BLEND IT INTO SECONDARY FUELS. DISPOSE OF
IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS . RCRA: NOT
A HAZARDOUS WASTE. U.S. EPA WASTE NUMBER: NONE.
=================== MSDS Transport Information ===================
Transport Information:U.S. DOT: 49 CFR 172.101 HAZARDOUS MATERIALS
TABLE. PROPER SHIPPING: NONE, NOT RESTRICTED. HAZARD CLASS OR
DIVISION: NONE. IDENTIFICATION NO: NONE. PACKING GROUP: NONE.
===================== Regulatory Information =====================
SARA Title III Information:NO REPORTABLE INGREDIENTS.
Federal Regulatory Information:TSCA: ALL INGREDIENTS ARE LISTED IN TSCA
INVENTORY.
State Regulatory Information:CALIFORNIA PROPOSITION 65: CONTAINS
NOTHING ON THIS LIST. WHMIS CLASS (CANADA): D-2B. NOTE: THIS MSDS
HAS BEEN PREPARED TO MEET WHMIS (CANADA) REQUIREMENTS WITH THE
EXCEPTION OF USING 16 HEADINGS.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:85106Q SYNTHETIC ENAMEL, TRACTOR & IMPLEMENT ENAMELS
Preparer's Name:T R LOUER
CAGE:23027
CAGE:90227
CAGE:23027
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE *96-4*
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 1%
OSHA PEL:2400 MG/CUM
ACGIH TLV:750 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SOYBEAN OIL, POLYMER W/GLYCEROL & PHTHALIC ANHYDRIDE
*96-4*
CAS:66070-61-9
Ingred Name:P-TERY-BUTYLBENZOIC ACID, PENTAERYTHRITOL, PHTHALIC
ANHYDRIDE, SOYBEAN OIL POLYMER
CAS:68083-25-0
Ingred Name:LINSEED OIL, POLYMER WITH CONJUGATED SAFFLOWER OIL,
GLYCEROL, ISOPHTHALIC ACID, ALKYD RESIN C
CAS:68213-52-5
Ingred Name:ALKYD RESIN H
Ingred Name:SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC, HIGH FLASH
AROMATIC NAPHTHA, C8&10 AROMATIC HYDROCARBON *96-4*
CAS:64742-95-6
RTECS #:WF3400000
Ingred Name:HEAVY AROMATIC SOLVENT NAPHTHA PETROLEUM *96-4*
CAS:64742-94-5
RTECS #:WF3100000
Ingred Name:LEAD NAPHTHENATE
CAS:61790-14-5
RTECS #:QK9150000
Fraction by Wt: 0.6%
Other REC Limits:0.10 MG/CUM
ACGIH TLV:0.15 MG/CUM INORG PB
Ingred Name:MEDIUM ALIPHATIC NAPHTHA (AROMATIC 100), PARAFFIN-NAPTHANES
MINERAL SPIRITS *96-4*
CAS:64742-88-7
Other REC Limits:100 PPM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
CARCINOGEN, IARC GROUP 3)*96-4*
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:TOLUENE (IARC CARC- GROUP 3) *96-4*
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 6%
Other REC Limits:375 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA, LACOLENE *96-4*
CAS:64742-89-8
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *96-4*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 2%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOLATILE ORGANIC CONTENT: 4.5 LBS/GAL
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: GASTROINTESTINAL DISTRESS.
INHALATION: NOSE & THROAT IRRITANT. REPEATED/PROLONGED OVEREXPOSURE
TO SOLVENTS MAY LEAD TO PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
EYES: IRRITATION/BURNING. SKI N: REPEATED/PROLONGED CONTACT MAY
CAUSEIRRITATION, DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:GI DISTRESS, IRRITATION, EYE WATERING,
HEADACHES, NAUSEA, DIZZIESS, LOSS OF COORDINATION, BURNING,
DISCOMFORT
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: IMMEDIATELY FLUSH
W/PLENTY OF WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:<73F
Lower Limits:0.8
Upper Limits:23
Extinguishing Media:WATER SPRAY, FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT W/SCBA. WATER
FROM FOG NOZZLES MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT
PRESSURE BUILDUP.
Unusual Fire/Explosion Hazard:WHEN HEATED >FLASHPOINT, EMITS FLAMMABLE
VAPORS WHICH, WHEN MIXED W/AIR, CAN BURN/BE EXPLOSIVE. FINE
MISTS/SPRAYS MAY BE FLAMMABLE AT TEMPS 120F. KEEP AWAY FROM
HEAT, SPARKS & FLAME. CLOSE CONTAINER AFTER EACH USE. GROUND
CONTAINERS WHEN POURING.
Other Precautions:DON'T SAND, FLAME CUT, BRAZE/WELD DRY COATING W/O A
NIOSH/MSHA APPROVED RESPIRATOR/APPROPRIATE VENTILATION. OBSERVE
LABEL PRECAUTIONS. DON'T BREATHE VAPORS/MISTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR PROPERLY FITTED VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA (TC-23C) FOR USE W/PAINTS DURING
APPLICATION/UNTIL ALL VAPORS & SPRAY MISTS ARE EXHAUSTED. CONFINED
SPACES: WEAR A POSITIVE-PRE SSURE, SUPPLIED-AIR RESPIRATOR
(TC-19C).
Ventilation:SUFFICIENT IN VOLUME & PATTERN TO KEEP CONTAMINANTS BELOW
APPLICABLE OSHA REQUIREMENTS.
Other Protective Equipment:COVERALLS
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE
EATING/SMOKING.
Supplemental Safety and Health
% VOLATILE BY VOLUME: 59.7-69.5%.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:129-734F
Vapor Density:>1
Evaporation Rate & Reference:LESS THAN ETHER
Solubility in Water:MISCIBLE
Percent Volatiles by Volume:(SUPP)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS, FLAME & OTHER IGNITION
SOURCES
Hazardous Decomposition Products:CO, CO2, SMOKE
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T ALLOW MATERIAL TO CONTAMINATE GROUND WATER
SYSTEMS. INCINERATE ABSORBED MATERIAL IAW/LOCAL, STATE & FEDERAL
REGULATIONS. DON'T INCINERATE IN CLOSED CONTAINERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CIS, CIS-MUCONONITRILE, 98%, 34894-5
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:CIS, CIS-MUCONONITRILE
CAS:1557-59-1
Fraction by Wt: 98%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY BE HARMFUL BY INHALATION,
INGESTION OR SKIN ABSORPTION. CAUSES EYE AND SKIN IRRITATION.
MATERIAL IS IRRITATING TO MUCOUS MEMBRANES AND UPPER RESPIRATORY
TRACT. TO THE BEST OF OUR KNOWLEDGE, THE CHEMICAL, PHYSICAL, AND
TOXICOLOGICAL PROPERTIES HAVE NOT BEEN THOROUGHLY INVESTIGATED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT
LEAST 15 MINUTES. SKIN: IMMEDIATELY WASH WITH SOAP AND COPIOUS
AMOUNTS OF WATER. WASH CONTAMINATED CLOTHING BEFORE REUSE. INHAL:
REMOVE TO FRESH AIR. IF NOT BREATHING GIVE ARTIFICIAL RESPIRATION.
IF BREATHING IS DIFFICULT, GIVE OXYGEN. INGEST: WASH OUT MOUTH WITH
WATER PROVIDED PERSON IS CONSCIOUS. CALL MD.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL POWDER OR
APPROPRIATE FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH/MSHA APPROVED RESPIRATOR, CHEMICAL
PLACE IN A BAG AND HOLD FOR WASTE DISPOSAL. AVOID RAISING DUST.
VENTILATE AREA AND WASH SP ILL SITE AFTER MATERIAL PICKUP IS
COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP TIGHTLY CLOSED. STORE IN A COOL
DRY PLACE.
Other Precautions:HARMFUL SOLID. IRRITANT. AVOID CONTACT WITH EYES,
SKIN AND CLOTHING. DO NOT BREATHE DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:>262F,>128C
Appearance and Odor:WHITE CRYSTALLINE POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF: CARBON MONOXIDE,
CARBON DIOXIDE, NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE OR MIX THE MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. DISPOSAL MUST BE IN ACCORDANCE WITH
APPLICABLE FEDERAL, STATE AND LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:RW-2577-82, PART B
Kit Part:Y
Preparer's Name:R W
CAGE:DO563
CAGE:83574
CAGE:DO563
============= Composition/Information on Ingredients =============
Ingred Name:POLYETHER POLYOL
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES & SKIN: TEMPORARY DISCOMFORT.
INHAL & INGEST: NONE KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LUKE WARM WATER FOR AT LEAST 15 MINUTES.
SKIN: WASH WITH SOAP AND WATER. INHAL & INGEST: NOT APPLICABLE.
===================== Fire Fighting Measures =====================
Flash Point:NON FLAMMABLE
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED AIR SUPPLIED
RESPIRATOR.
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP INTO CONTAINERS. CLEAN-UP RESIDUE WITH
1,1,1 -TRICHLOROETHANE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:GENERAL VENTILATION.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS FREQUENTLY AND THOROUGHLY DURING
CONTACT WITH MATERIAL AND AT END OF WORKDAY .
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:1.04
Solubility in Water:NEGLIGIBLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NO*X, CO*X
==================== Disposal Considerations ====================
Waste Disposal Methods:NOT A HAZARDOUS WASTE ACCORDING TO EPA
REGULATIONS. CONSULT STATE REGULATIONS PRIOR TO DISPOSAL OF
SPILLAGE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CASTROL 5299
Preparer's Name:RICARDO SIMMONS
CAGE:CASTI
CAGE:CASTI
CAGE:98308
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL, PETRO DISTILS, HYDROTREATED (SEV), HEAVY
NAPHTHENIC; (DISTILLATES (PETRO), HYDROTREATED HEAVY NAPHTHENIC)
CAS:64742-52-5
RTECS #:PY8035001
Fraction by Wt: 10-30%
OSHA PEL:5 MG/M3 (MIST) (MFR)
ACGIH TLV:5 MG/M3 (MIST) (MFR)
Ingred Name:MINERAL OIL, PETRO DISTILS, HYDROTREATED (SEVERE) HEAVY
NAPHTHENIC; (DISTILS (PETRO), HYDROTREATED LIGHT NAPHTHENIC)
CAS:64742-53-6
RTECS #:PY8036001
Fraction by Wt: 70-100%
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:CHLORONATED PARAFFIN; (ALKANES, C6-18, CHLORO)
CAS:68920-70-7
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES:CONCENTRATE MAY CAUSE
IRRITATION. SKIN ABSORPTION:NO ACUTE EFFECTS EXPECTED. SKIN
CONTACT:CONCENTRATE MAY CAUSE IRRITATION. INGEST:DO NOT INGEST.
CHRONIC:PROLONGED OR REPEATED CONTACT W/PET ROLEUM OIL MAY REMOVE
NATURAL OILS & FATS FROM SKIN. PETROLEUM DISTILLATES LISTED ARE
CLASSIFIED BY (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:SUPPLIER AS SEVERELY PROCESSED.
SPECIFIC CHLORINATED PARAFFIN INCL IN THIS PROD HAS NOT BEEN
TESTED/PROVEN TO CAUSE ADVERSE HLTH EFTS. OTHER CHLORINATED
PARAFFINS HAVE BEEN TESTED & SHOW EVID OF CARCIN IN LAB ANIMALS
VIA INGEST. THIS PROD CONTAINS AN ALKANOLAMINE. IN ALL METALWORKING
FLUIDS CONTAINING (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINUTES. GET
MEDICAL ATTENTION IF IRRITATION PERSISTS. SKIN:WASH W/SOAP & WATER.
IF IRRITATION OCCURS, GET MEDICAL ATTENTION. WASH CLOTHING BEFORE
REUSE. I NHAL:MOVE PERSON TO FRESH AIR. SEE MD IF DISCOMFORT OR
IRRITATION CONTINUES. INGEST:DO NOT INDUCE VOMITING; GET MEDICAL
ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:260F,127C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . COOL FIRE EXPOSED CONTAINERS W/WATER SPRAY TO PREVENT
RUPTURE.
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER FREE LIQUID. KEEP PRODUCT OUT OF
STREAMS & WATERWAYS BY DIKING OR IMPOUNDING. ADVISE AUTHORITIES IF
PRODUCT HAS ENTERED OR MAY ENTER SEWERS, WATERCOURSES OR EXTENSIVE
LAND AREAS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT ADD NITRITES TO THIS FLUID.
AVOID BREATHING MISTS. AVOID CONTACT W/EYES, SKIN & CLOTHING. DO
NOT INGEST. KEEP DRUMS CLOSED WHEN NOT IN USE.
Other Precautions:BRING PRODUCT TO ROOM TEMPERATURE BEFORE USE. DO NOT
STORE NEAR HEAT, FLAME, OR STRONG OXIDIZING AGENTS. DO NOT CUT OR
WELD EMPTY DRUMS UNLESS THOROUGHLY CLEANED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:INDUSTRIAL HYGIENE PRACTICES RECOMMEND THAT
ENGINEERING CONTROLS BE USED TO REDUCE ENVIRONMENTAL CONCENTRATIONS
TO TLV OR PEL. IF ANY ASSOCIATED TLV OR PEL IS EXCEEDED, PROVIDE
NIOSH/MSHA APPROVED RES PIRATORY PROTECTION.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:DELUGE SHOWER WHICH MEETS ANSI DESIGN
CRITERIA . EYEWASH FACILITY. APPROPRIATE CLOTHING TO AVOID SKIN
CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
SPEC GRAV:0.905-0.92 (H*2O=1). EFTS OF OVEREXP:AMINES, THERE IS POTNTL
FOR FORMING NITROSAMINES WHICH ARE ANIMAL CARCINOGENS. THEREFORE,
NO NITRITES OR RELATED NITROSATING AGENTS SHOULD BE ADDED TO SU CH
COMPOSITIONS.
================== Physical/Chemical Properties ==================
Vapor Pres:NEGLIGIBLE
Spec Gravity:SUPP DATA
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:DARK BROWN, TRANSPARENT OIL; FRAGRANCED ODOR.
Percent Volatiles by Volume:NEGLIG
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:POTENTIAL COMBUSTION PRODUCTS ARE HCL
(GAS) & OXIDES OF CARBON & SULFUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
REGULATIONS. DISPOSAL OF THIS MATERIAL TO LAND MAY BE BANNED BY
FEDERAL LAW (40 CFR 268).
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FLUOROFORM, MAT09970
Resp. Party Other MSDS Num.:MAT09970
CAGE:65169
CAGE:65169
CAGE:20816
============= Composition/Information on Ingredients =============
Ingred Name:FLUOROFORM
CAS:75-46-7
RTECS #:PB6900000
= Wt:100.
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: MILD IRRITATION,
NAUSEA, VOMITING, DIFFICULTY BREATHING, IRREGULAR HEARTBEAT,
HEADACHE, DROWSINESS, SYMPTOMS OF DRUNKENNESS, DISORIENTATION.
SKIN: BLISTERS, FROSTBITE. EYES: FROSTBI TE, BLURRED VISION.
INGESTION: FROSTBITE. CHRONIC: NO INFORMATION AVAILABLE.
Effects of Overexposure:SEE HEALTH HAZARDS. --STATE REGS: SKIN/EYES: NO
DATA AVAILABLE. INGESTION: A STUDY WITH RATS CAUSED INCREASED
MORTALITY AT HIGH DOSE LEVELS. REDUCED BODY WEIGHT AND BODY WEIGHT
CHANGE AND BLOOD EFFECT S MAY ALSO OCCUR AT HIGH DOSES.
======================= First Aid Measures =======================
First Aid:INHAL: WHEN SAFE TO ENTER AREA, REMOVE FROM EXPOS. USE BAG
VALVE MASK/SIMILAR DEVICE TO PERFORM ARTF RESP (RESCUE BRTHG) IF
NEEDED. KEEP WARM & AT REST. GET MED ATTN IMMED. SKIN: WASH IF
NEEDED. IF FR OSTBITE, FREEZING/CRYOGENIC BURNS OCCUR, WARM
AFFECTED AREA IN WARM WATER. IF NOT AVAIL, GENTLY WRAP AFFECTED
PARTS IN BLANKETS. ALLOW CIRCULATION TO RETURN NATURALLY. GET MED
ATTN IMMED. EYES: IT IS UNLIKELY THAT EMER TREATMENT WILL BE
REQUIRED. WASH W/LGE AMTS OF WATER/NORM SALINE UNTIL NO EVIDENCE OF
CHEM REMAINS (AT LEAST 15-20 MINS). GET MED ATTN IMMED. INGEST: IT
IS UNLIKELY THAT EMER TREATM ENT WILL BE REQUIRED. (SUP DAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, REGULAR DRY CHEMICAL. LARGE FIRES:
USE REGULAR FOAM OR FLOOD WITH FINE WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP .
MOVE CONTR FROM FIRE AREA IF IT CAN BE DONE W/OUT RISK. COOL CONTRS
W/WATER SPRAY UNTIL WELL AFTER FIRE IS OUT. STAY AWAY FROM ENDS OF
TANKS. WITHDRAW IMMED IN CASE OF RISING SOUND FROM VENTING SFTY
DEVICE/ANY DISCOLORATION OF TANKS DUE TO FIRE. (OTHER INFO)
Unusual Fire/Explosion Hazard:NEGLIGIBLE FIRE HAZARD. CONTAINERS MAY
RUPTURE OR EXPLODE IF EXPOSED TO HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:OCCUPATIONAL RELEASE: STOP LEAK IF POSSIBLE
WITHOUT PERSONAL RISK. KEEP UNNECESSARY PEOPLE AWAY, ISOLATE HAZARD
AREA AND DENY ENTRY. STAY UPWIND AND KEEP OUT OF LOW AREAS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AND HANDLE IN ACCORDANCE WITH
ALL CURRENT APPLICABLE REGULATIONS AND STANDARDS. SUBJECT TO
STORAGE REGULATIONS: U.S. OSHA 29 CFR 1910.101. KEEP SEPARATED FROM
INCOMPATIBLE SUBSTANCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:UNDER CNDTNS OF FREQUENT USE/HEAVY EXPOS, RESP
PROT MAY BE NEEDED. RESP PROT IS RANKED IN ORDER FROM MIN TO MAX, &
IS NIOSH APPRVD. CONSIDER WARNING PROPERTIES BEFORE USE. ANY
SUPP-AIR RESP W/FULL FAC EPIECE THAT IS OPERATED IN
PRESS-DEMAND/OTHER POS-PRESS MODE; ANY SCBA THAT HAS FULL FACEPIECE
& IS OPERATED IN PRESS-DEMAND/OTHER POSS-PRESS MODE. (SUP DAT)
Ventilation:PROVIDE LOCAL EXHAUST OR PROCESS ENCLOSURE VENTILATION
SYSTEM. ENSURE COMPLIANCE WITH APPLICABLE EXPOSURE LIMITS.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER . FOR THE GAS: PROTECTIVE CLOTHING IS NOT REQUIRED. FOR THE
LIQUID: WEAR APPROPRIATE PROTECTIVE, COLD INSULATING CLOTHING.
Work Hygienic Practices:CONTACT LENSES SHOULD NOT BE WORN.
Supplemental Safety and Health
FIRST AID PROC: GET MED ATTN, IF NEEDED. NOTE TO MD: FOR INHAL,
CONSIDER OXYGEN. RESP PROT: FOR UNKNOWN CONCS/IMMED DANGEROUS TO
LIFE/HLTH: ANY SUPP-AIR RESP W/FULL FACEPIECE & OPERATED IN
PRESS-DEMAN D/OTHER POSS-PRESS MODE IN COMBINATION W/SEPARATE
ESCAPE SUPPLY; ANY SCBA W/FULL FACEPIECE.
================== Physical/Chemical Properties ==================
Boiling Pt:=-82.2C, -116.F
Melt/Freeze Pt:=-160.C, -256.F
Decomp Temp:>260.C, 500.F
Vapor Pres:33592 MMHG @ 21C
Vapor Density:ECOL INFO
Viscosity:0.0144 CP @ 25C
Solubility in Water:0.1% @ 25C
Appearance and Odor:ODORLESS, COLORLESS GAS.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
METALS. ALUMINUM (POWDERED), CALCIUM, METALS (ACTIVE), POTASSIUM,
SODIUM, ZINC: POSSIBLE VIOLENT REACTION. MAGNESIUM AND ALLOYS: MAY
BE ATTACKED.
Stability Condition to Avoid:STABLE AT NORMAL TEMPERATURES AND
PRESSURE. PROTECT FROM PHYSICAL DAMAGE AND HEAT. CONTAINERS MAY
RUPTURE OR EXPLODE IF EXPOSED TO HEAT.
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCTS:
HALOGENATED COMPOUNDS, OXIDES OF CARBON.
=================== Toxicological Information===================
Toxicological Information:FLUOROFORM: TARGET ORGANS: CNS. MUTAGENIC
DATA: SEX CHROMOSOME LOSS & NON DISJUNCTION-DROSOPHILA MELANOGASTER
INHAL 98 PPH 10 MIN(S). ADDNL DATA: STIMULANTS SUCH AS EPINEPHRINE
MAY INDUCE VENTRICULAR FIBRILLATION. HLTH EFTS: ACUTE: INHAL MAY
CAUSE MILD IRRIT OF RESP TRACT. HIGHER CONCS MAY RSLT IN CNS
DEPRESS W/HDCH, DIZZ, TREMOR, DROW, DISORIENTATION, INCOORD, GIDD,
LT HEAD, & UNCON. SHORTNESS OF BRTH, NAUS & VOMIT MAY ALSO OCCUR.
CARD ARRHY & ARREST HAVE BEEN REPORTED. SIMPLE ASPHY MAY OCCUR AT
HIGH CONCS. SKIN: NO ADVERSE EFTS HAVE BEEN REPORTED FROM GAS. DUE
TO RAPID EVAP, LIQ MAY CAUSE FR OSTBT W/REDNESS, (STATE REGS)
===================== Ecological Information =====================
Ecological:NOT AVAILABLE. --PHYSICAL/CHEM PROPERTIES: MOLECULAR WT:
70.01; MOLECULAR FORMULA: C-H-F3; VAP DENS (AIR=1): 2.417 @ 25C;
DENSITY: 2.86 KG/M3; ODOR THRESHOLD: NOT AVAIL; COEFFICIENT OF
WATER/OIL DISTR IBUTION: N/A; SOLV SOL: SOL: ALCOHOL, ACETONE,
BENZENE, HYDROCARBONS, CHLORINATED SOLVS, KETONES, ESTERS, ORG
ACIDS; INSOL: GLYCOLS, GLYCEROL, PHENOLS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
REGULATIONS. DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS .
=================== MSDS Transport Information ===================
Transport Information:U.S. DOT 49 CFR 172.101: SHIPPING NAME-UN #:
TRIFLUOROMETHANE-UN1984; HAZ CLASS/DIVISION: 2.2; SUBPART E
LABELING REQS: NONFLAM GAS; PACKAGING AUTHORIZATIONS: EXCEPTIONS:
49 CFR 173.306; NON-BULK PACK AGING: 40 CFR 173.304; BULK
PACKAGING: 40 CFR 173.314, 315; QTY LIMITATIONS: PASSENGER
AIRCRAFT/RAILCAR: 75 KG; CARGO AIRCRAFT ONLY: 150 KG. LAND
TRANSPORT ADR/RID: SUBSTANCE NAME: TRIFLUOROMETHANE (R
23)/TRIFLUOROMETHANE (REFRIGERANT GAS R 23); UN #: UN1984; ADR/RID
CLASS: 2; ITEM #: 5 (A)/2A; WARNING SIGN/LABEL: 2/2, 13; HAZ ID #:
20. AIR TRANSPORT IATA/ICAO: CORRECT TECHNICAL NAME: TRIFLUOROMET
HANE (R23)/ (SARA REGS)
===================== Regulatory Information =====================
SARA Title III Information:SARA SECTION 302 (40 CFR 355.30): N. SARA
SECTION 304 (40 CFR 355.40): N. SARA SECTION 313 (40 CFR 372.65):
N. SARA HAZARD CATEGORIES, SARA SECTIONS 311/312 (40 CFR 370.21):
ACUTE: Y; CHRONIC: N; FIRE : N; REACTIVE:N; SUDDEN RELEASE: Y.
--TRANSPORT INFO: TRIFLUOROMETHANE; UN/ID #: UN1984; IATA/ICAO
CLASS: 2.2; LABEL: NONFLAM GAS. MARITIME TRANSPORT IMDG: CORRECT
TECHNICAL NAME: TRIFLUOROMETHANE; UN /ID #: UN1984; IMDG CLASS: 2
(2.2); EMS #: 2-09; MFAG TABLE #: 350; MARINE POLLUTANT: N.
Federal Regulatory Information:U.S. REGULATIONS: TSCA INVENTORY STATUS:
Y. TSCA 12(B) EXPORT NOTIFICATION: NOT LISTED. CERCLA SECTION 103
(40 CFR 302.4): N. OSHA PROCESS SAFETY (29 CFR 1910.119): N.
EUROPEAN REGULATIONS: EC NUMBER (EINECS): 200-872-4. GERMAN
REGULATIONS: WATER HAZARD CLASS (WGK): 0 (SELF CLASSIFICATION BY
MANUFACTURERS AND DISTRIBUTORS); WATER HAZARD CLASS (WGK): 1 (SELF
CLASSIFICATION BY MANUFACTURERS AND DIST RIBUTORS).
State Regulatory Information:CALIFORNIA PROPOSITION 65: N. --TOX INFO:
TINGLING & PAIN/NUMBNESS. IN MORE SEV CASES, SKIN MAY BECOME HARD &
WHITE & DEVELOP BLISTERS. EYES: NO ADVERSE EFTS HAVE BEEN REPORTED
FROM GAS. DUE TO RAPID EVAP, LIQ MAY CAUSE FROSTBT W/REDNESS, PAIN
& BLURRED VISION. INGEST OF GAS IS UNLIKELY. IF LIQ IS SWALLOWED,
FROSTBT DMG TO LIPS, MOUTH & MUC MEMBS MAY OCCUR. CHRONIC: INHAL:
MATED RATS EXPOSED TO 50 ,000 PPM ON DAYS 7-21 OF GESTATION RSLTD
IN SIGNIFICANT INCR IN INCIDENCE OF SML RENAL PAPILLA. IN A DDN, AT
20,000 & 50,000 PPM THERE WERE STATISTICALLY SIGNIFICANT INCRS IN
INCIDENCE OF RETARDED STERNEBRAL OSSIFICATION. (EFTS OF OVERREXP)
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CAT-MIL-C-83286, GRAY 36622,ID 03GY62CAT
Kit Part:Y
CAGE:DO188
CAGE:33461
CAGE:DO188
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ISOBUTYL KETONE (SARA III)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 10%
OSHA PEL:100 PPM/75 STEL
ACGIH TLV:50 PPM/75 STEL; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-ETHOXYETHYL ACETATE (CELLOSOLVE ACETATE) (EGEEA)
CAS:111-15-9
RTECS #:KK8225000
Fraction by Wt: 5%
OSHA PEL:S,100 PPM
ACGIH TLV:S, 5 PPM; 9192
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <5%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BIURETR OF 1,6 HEXAMETHYLENE DIISOCYANATE
CAS:28182-81-2
RTECS #:NQ9170000
Fraction by Wt: 30%
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: <5%
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: <5%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 45%
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VOC. ORGANIC CMPD 5.29 LB/GL LESS WATER & NPRS* 634 G/L
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: VAPORS OR MIST CAN IRRITATE THE
MUCOUS MEMBRANES IN THE RESPIRATORY TRACTCAUSING RUNNY NOSE, SORE
THROAT, COUGHING, CHEST DISCOMFORT, SHORTNESS OF BREATH& REDUCE
LUNG FUNCTION. CHRONIC:CAN DEVE LOPE ISOCYANATE SENSITIZATION WHICH
WILLCAUSE THEM TO REACT TO A LATER EXPOSURE TO ISOCYANATE AT LEVELS
WELL BELOW TLV.
Effects of Overexposure:EYE: IRRITATING & CAUSE TEARING, REDNESS, &
SWELLING ALONG W/STINGING SENSATION SKIN: ISOCYANATES REACT W/SKIN
PROTEIN & MOISTURE, CAN CAUSE IRRITATION, RASH.
INHL:HEADACHE,DIZZINESS,STAGGERING GAIT, CONFUSION,
UNCONSCIOUSNESS, OR COMA.INGST:CORROSIVE ACTION IN MOUTH,STOMACH
TISSUE,DIGESTIVE TRACT.
Medical Cond Aggravated by Exposure:VOMITING MAY CAUSE ASPIRATION OF
THE SOLVENT RE- SULTING IN CHEMICAL PNEUMONITIS.
ISOCYANATE SENSITIZATION, ASTHMA, DERMITITIS.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING,WASH AFFECTED AREA W/SOAP &
WATER. EYE:FLUSH W/CLEAN, LKWARM WATER FOR 15 MINS.
LIFTING EYELIDS OCCASIONALLY. INHAL:MOVE TO FRESH AIR. RESTORE
BREATHI NG. ASTHMATIC TYPE SYMPTOMS MAY DEVEL.OBTAIN MEDICAL
ATTENTION. INGST: DO NOT INDUCE VOMITING. DONOT GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS PERSON. OBTAIN MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:23F/-500C
Lower Limits:1.0
Upper Limits:11.5
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:FULL EQUIPMENT WITH SELF VONTAINED BREATHING
APPARATUS AND FULL PROTECTIVE CLOTHING SHOULD BE WORN BY
FIREFIGHTER.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT,SPARKS,ELEC. EQUIP., & FLAME. CLOSED CONTAINERS MAY
EXPLODE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE
AREA. CONTAIN & REMOVE W/INERT ABSORBENT & NONSPARKING TOOLS.
EVACUATE ALL PERSONNEL.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID STORING NEAR HIGH
TEMP.,FIRE,SPARK SOURCES. STORE IN TIGHTLY CLSD CONTNR TO PREVENT
MOISTURE. HANDLE W/CARE DUE TO RESIDUE & FLAMMABLE VAPOR.
Other Precautions:KEEP CONTAINERS TIGHT & UPRIGHT TO PREVENT LEAKAGE.
IF MOISTURE ENTERS CONTAINERPRESSURE CAN BUILD UP DUE TO A REACTION
PRODUCING CO2 WHICH CAN CAUSE A SEALED CONTAINER TO BURST. DO NOT
RESEAL IF CON TAMINATION IS SUSPECTED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR THAT IS AIR PURIFYING OR FRESH AIR
SUPPLIED IS NECESSARY. VENTILATION SHOULD BE PROVIDED TO
KEEP EXPOSURES BELOW THE OSHA LIMITS.
Ventilation:LOCAL EXHAUST VENTILATION IS SUFFICIENT TO KEEP THE
AIRBORNECONCENTRATIONS OF THE SOLVENT.
Other Protective Equipment:LONG SLEEVE AND LONG LEG CLOTHING.
Work Hygienic Practices:WASH HANDS BEFORE EATING,SMOKING,USING
WASHROOM. WASH CONTAMINATED CLOTHING BEFORE REUSE. SMOKE IN SMOKING
AREAS ONLY.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:175-313F
Vapor Density:> AIR
Spec Gravity:0.9
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBE
Appearance and Odor:CLEAR, LIGHT AMBER WITH SOLVENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER,AMINES, STRONG BASES, ALCOHOL, METAL COMPOUNDS & SURFACE
ACTIVE MATERIALS.
Stability Condition to Avoid:MOISTURE, MATERIALS WHICH REACT WITH
ISOCYANATES, AND HIGH TEMPERATURES.
Hazardous Decomposition Products:CARBON DIOXIDE/MONOXIDE, OXIDES OF
NITROGEN, TRACES OF HDN, HDI.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE,
AND LOCAL REGULATIONS. DONOT INCINERATE CLOSED CONTNRS
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SYSTEM 2000 82007 PREPOLYMER-WHITE
Kit Part:Y
CAGE:53472
CAGE:70842
CAGE:0NBN5
CAGE:53472
============= Composition/Information on Ingredients =============
Ingred Name:DIISOCYANATE (HOMOPOLYMER)
CAS:39310-05-9
Fraction by Wt: 40-50%
Other REC Limits:NONE RECOMMENDED
Ingred Name:METHYLENE BISPHENYL ISOCYANATE (MDI) (SARA 313)
CAS:101-68-8
RTECS #:NQ9350000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 0.02 PPM
ACGIH TLV:0.005 PPM; 9596
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:URETHANE PREPOLYMER
Fraction by Wt: 23-27%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.005 PPM TDI
ACGIH TLV:0.005 PPM TDI
Ingred Name:TALC (CONTAINING ASBESTOS)
CAS:14807-96-6
RTECS #:MW2700000
Fraction by Wt: 10-25%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:0.2 FIBER/CC,A1;9596
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: .1-.25%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST;9596
Ingred Name:SILICA, AMORPHOUS (FUMED)
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:URETHANE PREPOLYMER
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.005 PPM TDI
ACGIH TLV:0.005 PPM TDI
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT GIVEN FOR PRODUCT AS A WHOLE
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION CAN CAUSE NASAL &
RESPIRATOY IRRITATION. PROLONGED INHALATION OF TALC DUST CAN CAUSE
PULMONARY FIBROSIS. SKIN CONTACT MAY CAUSE IRRITATION. REPEATED
EXPOSURE MAY CAUSE SENSITIZATION. EYE CO NTACT MAY CAUSE
IRRITATION. INGESTION CAN CAUSE GASTRINTESTINAL IRRIATION, NAUSEA,
VOMITING, DIARRHEA.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:NASAL IRRITATION, RESPIRATORY TRACT IRRITATION,
TIGHTNESS OF CHEST, COUGHING, HEADACHE, PULMONARY FIBROSIS, SKIN
IRRITATION/REDNESS/BURNING, SKIN SENSITIZATION, EYE
IRRITATION/STINGING/TEARING/REDNESS , GI TRACT IRRITATION, NAUSEA,
VOMITING, DIARRHEA. CONTAINS QUARTZ, KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH WITH SOAP AND WATER. IF IRRITATION PERSIST, GET MEDICAL
ATTENTION. INH ALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. GET
MEDICAL ATTENTION. INGESTION: IMMEDIATELY DRINK 2 GLASSES OF WATER
& INDUCE VOMITING. NEVER GIVE ANYTHING BY MOUTH IF UNCONSCIOUS. GET
PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>200F,>93C
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:FOAM, ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL,
WATER FOG
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR SELFCONTAINED
BREATHING APPARATUS AND FULL PROTECTIVE GEAR. WATER OR FOAM MAY
CAUSE FROTHING WHICH CAN BE VIOLENT & POSSIBLE DANGEROUS
Unusual Fire/Explosion Hazard:NEVER USE WELDING OR CUTTING TORCH ON OR
NEAR DRUM (EVEN EMPTY) BECAUSE PRODUCT (EVEN RESIDUE) CAN IGNITE
EXPLOSIVELY.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SPILL ON VERMICULITE, FLOOR ABSORBENT,
OTHER ABSORBENT MATERIAL. PLACE IN A CLEAN, DRY, LEAK-PROOF
CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:EMPTY CONTAINERS RETAIN RESIDUE AND
CAN BE DANGEROUS. DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER,
DRILL, GRIND OR EXPOSE SUCH CONTAINERS TO HEAT.
Other Precautions:WEAR IMPERVIOUS CLOTHING AND BOOTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURE MAY OR DOES EXCEED OCCUPATION
EXPOSURE LIMITS USE A NIOSH-APPROVED RESPIRATOR TO PREVENT
OVEREXPOSURE. IN ACCORD WITH 29 CFR 1910.134 USE EITHER AN
ATMOSPHERE-SUPPLYING RESPIRATOR OR AN AI R-PURIFYING RESPIRATOR.
Ventilation:EXHAUST VENTILATION SUFFICIENT TO KEEP AIRBORNE
CONCENTRATIONS BELOW RESPECTIVE TLV'S.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
================== Physical/Chemical Properties ==================
HCC:V7
Boiling Pt:B.P. Text:392F,200C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Decomp Temp:Decomp Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:NOT GIVEN
Spec Gravity:1.288
Viscosity:NOT GIVEN
Evaporation Rate & Reference:< 1 (ETHER=1)
Solubility in Water:NOT GIVEN
Appearance and Odor:WHITE LIQUID, NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, STRONG MINERAL ACIDS, WATER.
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
Conditions to Avoid Polymerization:CONTACT WITH STRONG ALKALIES, STRONG
MINERAL ACIDS, WATER.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CARQUEST 10W40
CAGE:IO754
CAGE:IO754
CAGE:72527
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, SOLVENT-DEWAXED
(SEVERE), HEAVY PARAFFINIC; (ALIPHATIC PETROLEUM DISTILLATES)
CAS:64742-65-0
RTECS #:PY8038501
Fraction by Wt: 83-93%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DETERGENT/DISPERSANT ENGINE OIL PACKAGE
Fraction by Wt: 6-16%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PHOSPHORODITHOIC ACID, O-O-D1 C1-14-ALKYL ESTERS, ZINC
SALTS (2:1) (ZDDP); (ZINC COMPOUNDS)
CAS:68649-42-3
Fraction by Wt: 1.1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUP DAT: PUMP LIQ TO SALVAGE TANK. REMAINING LIQ MAY BE
TAKEN UP ON SAND, CLAY, EARTH, FLOOR ABSORB/OTHER (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: ABSORBENT MATERIAL AND SHOVELED INTO CONTAINERS.
RTECS #:9999999ZZ
Ingred Name:VENT: SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW PEL/TLV.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: MAY CAUSE MILD IRRIT
W/STINGING, TEARING & REDNESS. SKIN: MAY CAUSE MILD IRRIT.
PRLNG/RPTD EXPOS MAY DRY SKIN. SYMPS MAY INCL REDNESS, BURNING,
DRYING & CRACKING, & BURNS. INGEST: SINGLE D OSE ORAL TOXICITY IS
LOW. SWALLOWING SML AMTS DURING NORM HNDLG IS NOT LIKELY TO CAUSE
HARMFUL EFTS, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:MILDLY REFINED MINERAL OIL: IARC
MONOGRAPHS, SUPPLEMENT, VOLUME 7, PAGE 252, 1987: GROUP 1.
Effects of Overexposure:HLTH HAZ: SWALLOWING LGE AMTS MAY BE HARMFUL.
INHAL: EXPOS IS POSS UNDER CERTAIN CNDTNS OF HNDLG & USE (FOR
EXAMPLE, DURING HEATING, SPRAYING/STIRRING). SYMPS ARE MORE
TYPICALLY SEEN AT AIR CONCS EXCE EDING REC EXPOS LIMITS. SYMPS OF
EXPOS:GI IRRIT (NAUS, VOMIT, DIARR), IRRIT (NOSE, THROAT, RESP
TRACT), ABDOM PAIN.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN DISORDERS MAY BE
AGGRAVATED BY EXPOSURE TO THIS MATERIAL. PREEXISTING LUNG DISORDERS
(ASTHMA-LIKE CONDITIONS) MAY BE AGGRAVATED BY EXPOSURE TO THIS
MATERIAL.
======================= First Aid Measures =======================
First Aid:EYES: MOVE INTO FRESH AIR. FLUSH EYES GENTLY W/WATER WHILE
HOLDING EYELIDS APART FOR AT LEAST 15 MIN. IF SYMPS PERSIST/THERE
IS ANY VISUAL DFCLTY, SEEK MED ATTN. SKIN: REMOVE CONTAM CLTHG.
WASH EXPOSE D AREA W/SOAP & WATER. IF SYMPS PERSIST, SEEK MED ATTN.
LAUNDER CLTHG BEFORE REUSE. INGEST: DO NOT INDUCE VOMIT. GIVE 1
GLASS OF MILK/WATER, & GET MED ATTN IMMED. IF POSS, DO NOT LEAVE
VICTIM(SUP DAT)
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:435F,224C
Extinguishing Media:REGULAR FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER OR FOAM MAY CAUSE FROTHING WHICH CAN BE VIOLENT
AND POSSIBLY ENDANGER LIFE OF FIREFIGHTER.
Unusual Fire/Explosion Hazard:NEVER USE WELDING/CUTTING TORCH ON/NEAR
DRUM (EVEN EMPTY) BECAUSE PROD (EVEN JUST RESIDUE) CAN IGNITE
EXPLOSIVELY. DENSE SMOKE MAY BE GENERATED WHILE BURNING.
================== Accidental Release Measures ==================
Spill Release Procedures:SML SPILL: ABSORB LIQ ON VERMICULITE, FLOOR
ABSORB/OTHER ABSORB MATL. LGE SPILL: PVNT RUN-OFF TO SEWERS,
STREAMS/OTHER BODIES OF WATER. IF RUN-OFF OCCURS, NOTIFY PROPER
AUTH AS REQUIRED, THAT SPILL HA S OCCURRED. PERS NOT WEARING PROT
EQUIP(SUP DAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTAINERS OF THIS MATERIAL MAY BE
HAZARDOUS WHEN EMPTIED.
Other Precautions:SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUE
(VAPOR, LIQUID, AND/OR SOLID), ALL HAZARD PRECAUTIONS GIVEN IN THIS
MSDS MUST BE OBSERVED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER NORMAL CONDITIONS OF USE.
HOWEVER, IF OIL MISTS ARE GENERATED ABOVE RECOMMENDED PEL/TLV OF 5
MG/M3, A NIOSH APPROVED RESPIRATOR IS ADVISED IN ABSENCE OF PROPER
ENVIRONMENTAL CONTROL (CONSULT YOUR INDUSTRIAL HYGIENIST).
Ventilation:NOT REQUIRED UNDER NORMAL CONDITIONS OF USE. HOWEVER, IF
UNUSUAL OPERATING CONDITIONS EXIST, THEN PROVIDE (ING 6)
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH & DELUGE
SHOWER . WEAR NORMAL WORK CLOTHING COVERING ARMS AND LEGS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: UNATTENDED. INHAL: IMMED MOVE INTO FRESH AIR. SEEK
IMMED MED ATTN; KEEP WARM & QUIET. IF NOT BRTHG, BEGIN ARTF RESP.
IF BRTHG IS DFCLT, ADMIN OXYGEN. SPILL PROC: SHOULD BE EXCLUDED FRO
M AREA OF SPILL UNTIL CLEAN-UP HAS BEENCOMPLETED. STOP SPILL AT
SOURCE, DIKE AREA OF SPILL TO PVNT SPREADING, (ING 4)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:425F,218C
Spec Gravity:0.881
Evaporation Rate & Reference:SLOWER THAN ETHYL ETHER
Appearance and Odor:DRY, CLEAR AND BRIGHT LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE AND CARBON MONOXIDE,
OXIDES OF SULFUR, NITROGEN AND PHOSPHORUS, VARIOUS HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ACRYLIC ENAMEL, 80-424 DURONODIC BRONZE
CAGE:33200
CAGE:33200
============= Composition/Information on Ingredients =============
Ingred Name:PIGMENTS
Fraction by Wt: 12.2%
Ingred Name:VEHICLE
Fraction by Wt: 26.7%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 52.9%
Ingred Name:DIETHYLENE GLYCOL;(CARBITOL)
CAS:111-46-6
Fraction by Wt: 8.2%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST: IF SWALLOWED, INDUCE VOMIT, CALL PHYS. EYES: FLUSH
WITH POTABLE WATER FOR AT LEAST 15 MIN, SEE MD . INHAL: REMOVE TO
FRESH AIR. SUPPORT BRTHG. (GIVE O*2/ARTF RESP) . SKIN: WASH WIT H
SOAP AND WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE CONDITIONS .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH AWAY WITH WATER OR ABSORB ON APPROPRIATE
ABSORBANT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST: ONLY TO AVOID EXCESSIVE INHAL WHEN SPRAYING.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:WATER
Vapor Density:>1
Spec Gravity:1.116
Evaporation Rate & Reference:1(WATER=1)
Solubility in Water:INFINITE
Appearance and Odor:BROWN OPAQUE LIQUID, SLIGHTLY SWEET ODOR.
Percent Volatiles by Volume:68.1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:FREEZING TEMPERATURES.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FA1191
CAGE:JO867
CAGE:81831
CAGE:JO867
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDAIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR. AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE U NCONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PHOSPHATE CHEMETS, VACUETTES & VACUVIALS, R
CAGE:7K791
CAGE:7K791
============= Composition/Information on Ingredients =============
Ingred Name:MOLYBDIC ACID, HEXAMMONIUM SALT (AMMONIUM MOLYBDATE)
CAS:12027-67-7
RTECS #:QA5076000
Fraction by Wt: <1.0%
Ingred Name:SULFURIC ACID (SARA III)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 5.0%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:DEIONIZED WATER
CAS:77-18-5
Fraction by Wt: >94.0%
Ingred Name:THE FOLLOWING PHYSICAL, HEALTH, FIRE, ETC DATA IS PROVIDED
FOR INGREDIENT 02 (SULFURIC ACID).
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:MAY CAUSE IRRITATION,
CONJUNCTIVITIS AND LACRIMATION. SKIN:MAY CAUSE IRRITATION AND
DERMATITIS. COULD CAUSE SEVERE BURNS. INHAL:MAY CAUSE COUGHING AND
IRRITATION OF THE UPPER RESPIRATORY TRACT. IN GEST:MAY CAUSE BURNS
OF THE MUCOUS MEMBRANES OF THE THROAT, ESOPHAGUS AND STOMACH.
Explanation of Carcinogenicity:NONE SPECIFIED BY MANUFACTURER.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH CONTINUOUSLY W/COPIOUS AMTS OF WATER FOR AT LEAST
15 MINS. FORCIBLY HOLD EYELIDS APART TO ENSURE IRRIGATION OF ALL
EYE/LID TISSUE. SEEK PROMPT MED ATTN. SKIN:WASH AFFECTED AREAS
W/SOAP/MILD DETERGENT & LGE AMTS OF WATER. IN CASE OF CHEM BURNS,
COVER AREA W/STERILE DRY DRESSING. SEEK PROMPT MED ATTN.
INHAL:REMOVE INDIVIDUAL TO FRESH AIR IMMED. SUPPORT BRTHG (GIVE
O*2/ (SEE SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:DRY CHEMICAL OR CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP COMBUSTIBLES AWAY FROM SPILLED MATERIAL.
DO NOT TOUCH SPILLED MATERIAL. TAKE UP W/SAND OR OTHER ABSORBENT
MATERIAL AND PLACE INTO SMALL CONTAINERS FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:WEAR EYE & SKIN PROTECTION.
VENTILATION RECOMMENDED.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST VENTILATION.
Other Protective Equipment:IMPERVIOUS CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: ART RESP) . SEEK PROMPT MED ATTN. INGEST:IF VICTIM IS
CONSCIOUS AND NOT CONVULSIVE, IMMEDIATELY GIVE THE VICTIM LARGE
QUANTITIES OF WATER TO RINSE THE MOUTH. THEN GIVE MILK MIXED W/EGG
WHITES TO DRINK. DON NOT INDUCE VOMITING. SEEK PROMPT MEDICAL
ATTENTION.
================== Physical/Chemical Properties ==================
HCC:C2
Boiling Pt:B.P. Text:536F,280C
Melt/Freeze Pt:M.P/F.P Text:37.0F,2.8C
Vapor Pres:0.001@20C
Vapor Density:3.4
Spec Gravity:1.8
Solubility in Water:SOLUBLE
Appearance and Odor:LIQUID, COLORLESS TO DARK BROWN, OILY
================= Stability and Reactivity Data =================
VIOLENT EXOTHERMIC REACTION W/WATER OR STEAM AND ORGANIC MATERIALS.
COULD IGNITE FINELY DIVIDED COMBUSTIBLE MATERIALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCTS INCLUDE
HIGHLY TOXIC FUMES OF SULFUR OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF BY MEANS AS TO COMPLY W/ALL LOCAL,
STATE AND FEDERAL REGULATIONS OR CONTACT AN APPROVED AND LICENSED
DISPOSAL AGENCY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ABRASIVE FLAP WHEEL, FLAPWHL
Preparer's Name:B ABBOTT
CAGE:JO676
CAGE:55649
CAGE:JO676
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM OXIDE (SARA 313)
CAS:1344-28-1
RTECS #:BD1200000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9495
Ingred Name:PHENOLIC FORMALDEHYDE RESIN
CAS:68583-74-4
RTECS #:9999999ZZ
OSHA PEL:5 PPM (MFR)
ACGIH TLV:5 PPM (MFR)
Ingred Name:CRYOLITE
CAS:1327-39-5
RTECS #:9999999ZZ
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: DUST MAY CAUSE MECHANICAL
IRRITATION. INHALATION: INHALATION OF DUST MAY CAUSE IRRITATION.
COUGHING AND SNEEZING. INGESTION: NO ADVERSE EFFECTS FROM INGESTION
ARE KNOWN. SKIN: THE ABRASIV E NATURE OF SANDING DISCS MAY CAUSE
DAMAGE TO THE SKIN IF DIRECT CONTACT OCCURS. DUST FROM SANDING
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: MAY CAUSE MECHANICAL IRRITATION.
CHRONIC: THERE ARE NO CHRONIC EFFECTS KNOWN. TARGET ORGANS: NONE
KNOWN.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM AREA TO FRESH AIR. SEEK MED ATTN IF RESP
IRRIT DEVELOPS/IF BRTHG BECOMES DFCLT. EYE: RINSE W/H*2O. REMOVE
ANY CONTACT LENSES & CONTINUE FLUSHING W/PLENTY OF H*2O FOR AT
LEAST 15 MIN . SEEK MED ATTN IF IRRIT DEVELOPS. SKIN: WASH AFFECTED
AREAS W/PLENTY OF SOAP & H*2O FOR SEVERAL MIN. SEEK MED ATTN IF
IRRIT DEVELOPS. INGEST: GIVE 3 TO 4 GLASSES OF H*2O, BUT DO NOT
(SUPDAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:CO*2, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:TRACE AMOUNTS OF FORMALDEHYDE MAY BE
RELEASED UPON BURNING.
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP PRODUCT AND INSPECT FOR TORN OR DAMAGE
AREAS. DO NOT USE IF PRODUCT IS TORN OR DAMAGE.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:FOLLOW PROCEDURES SET FORTH IN ANSI
STANDARD B7.1.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. READ THE ENTIRE LABEL
BEFORE USING THIS PRODUCT. OBSERVE PROPER RUNNING SPEEDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH APPROVED DUST RESPIRATOR.
Ventilation:USE LOCAL EXHAUST VENTILATION.
Other Protective Equipment:ANSI APPRVD EMER EYE WASH & DELUGE SHOWER .
SAFETY SHOES, FIRE PROOF CLOTHING, HEAD PROTECTION & HEARING
(SUPDAT)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: INDUCE VOMITING. IF VOMITING OCCURS, GIVE FLUIDS AGAIN.
GET IMMEDIATE MEDICAL ATTENTION IF DISCOMFORT OCCURS. NOTES TO
PHYSICIAN: NONE KNOWN. OTHER PROT EQUIP: PROTECTION. USE WHEEL GU
ARDS.
================== Physical/Chemical Properties ==================
Evaporation Rate & Reference:0 (BU A/C = 1)
Appearance and Odor:BROWNISH; NO ODOR.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:MAY EMIT FUMES CONTAINING TRACES
AMOUNTS OF FORMALDEHYDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL,
LOCAL, AND STATE REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:786-202,TT-L-32A TY II,ORANGE 12197
CAGE:09869
CAGE:09869
============= Composition/Information on Ingredients =============
Ingred Name:ISOBUTYL ALCOHOL (SARA III)
CAS:78-83-1
RTECS #:NP9625000
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOBUTYL ACETATE (SARA III)
CAS:110-19-0
RTECS #:AI4025000
OSHA PEL:150 PPM
ACGIH TLV:150 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL BENZENE (SARA III)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: <5.0%
OSHA PEL:100 PPM/125 STEL
ACGIH TLV:100 PPM/125STEL 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:2-ETHOXYETHYL ACETATE (CELLOSOLVE ACETATE) (EGEEA)
CAS:111-15-9
RTECS #:KK8225000
Fraction by Wt: <5.0%
OSHA PEL:S,100 PPM
ACGIH TLV:S, 5 PPM; 9192
Ingred Name:METHYL ISOBUTYL KETONE (SARA III)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: <5.0%
OSHA PEL:100 PPM/75 STEL
ACGIH TLV:50 PPM/75 STEL; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:INH:ANESTHETIC,IRRIT OF RESP TRACT OR ACUTE CNS
DEPRSSN W/HDACHE,DIZ,UNCON,COMA. SKIN & EYE:IRRITJ
======================= First Aid Measures =======================
First Aid:IN CASE OF CONTACT, FLUSH SKIN & EYES W/PLENTY OF WATER WHILE
REMOVING CONTAMINATED CLOTHING. IF INHALED, REMOVE TO FRESH AIR.
CALL A MD IF SYMPTOMS PERSISIT.
===================== Fire Fighting Measures =====================
Flash Point:30F TCC
Lower Limits:0.9
Extinguishing Media:SM FIRES:CO*2,DRY CHEM.LG FIRES:POLYMER FOAM
PREFERRED
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS EXPOSED TO HEAT MAY
EXPLODE DUE TO PRESSURE BUILD-UP
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE AL SOURCES OF IGNITION (FLAME, HOT
SURFACES, & ELECTRICAL,STATIC,OR FRICTIONAL SPARKS).AVOID BREATING
VAPORS.VENTILATE AREA.REMOE W/INERT ABSORBENT & NON-SPARKING
TOOLS.-
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F.STORE LG QTY
IN BLDG DESIGNED TO STORE NFPA CLASS ONE FLAM LIQ.DO NOT TAKE
INTERNALLY. ADD LABEL WARNING.
Other Precautions:GROUND CONTAINERS WHEN POURING.AVOID FREE FALL OF LIQ
IN EXCESS OF FEW IN.DO NOT FLAME CUT,BRAZE OR WELD COATED MATERIAL
W/O APROVED RESPIRATOR OR APPROPRIATE VENTILATION. DOT :FLAM LIQ.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESTRICT VENT:CHEM-MECH FLTR.CLSD:AIR-LINE TYPE
Ventilation:GEN DILTN/LOCAL EXHST TO KEEP TLV/LEL BELOW LIMIT,REMV FUME
Other Protective Equipment:AVOID LONG EXPOSURE TO CONTAM CLOTHING
Supplemental Safety and Health
VAP-DENSITY:>1;ALSO HAS:VM&P NAPHTHA,11-21% TLV 200 PPM
MFG;ISOPROPANOL,<5% TLV:S,400 PPM;MEK<0.5% TLV 200 PPM. HIGHEST
V.P. OF A SINGLE COMPONENT IS 70.6 MMHG.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:174-329F
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:74.4
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:AVOID FIRES, HEAT & HOT SURFACES
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE CLOSED CONTAINER. DISPOSE IN
ACCORDANCE W/FED, STATE & LOCAL CODES.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:RP 3260 RESIN
Kit Part:Y
Preparer's Name:PETER HENIGE
CAGE:02684
CAGE:02684
============= Composition/Information on Ingredients =============
Ingred Name:LITHOPONE
CAS:1345-05-7
RTECS #:OJ6600000
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 DUST
ACGIH TLV:10 MG/M3 DUST
Ingred Name:SILICON CARBIDE
CAS:409-21-2
RTECS #:VW0450000
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:DIGLCIDYL ETHER OF BISPHENOL A
CAS:25068-38-6
RTECS #:KD4380000
Other REC Limits:NONE SPECIFIED
Ingred Name:BUTOXYMETHYL OXIRANE
CAS:2426-08-6
RTECS #:TX4200000
Other REC Limits:NONE SPECIFIED
OSHA PEL:50 PPM
ACGIH TLV:25 PPM; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION. EYE IRRITATION.
SENSITIZATION: POSSIBLE IN SUSCEPTIBLE INDIVIDUALS.
Effects of Overexposure:SKIN AND EYE IRRITATION AND ALLERGIC SKIN AND
RESPIRATORY REACTIONS.
Medical Cond Aggravated by Exposure:SKIN AND EYE CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYE: IMMED FLUSH W/WATER 15 MINUTES. CALL PHYSICIAN. SKIN:
WASH W/SOAP/WATER. REMOVE CONTAMINATED CLOTHING/LAUNDER BEFORE
REUSE. INGEST: IF CONSCIOUS, GIVE PLENTY OF WATER. DONT INDUCE
VOMIT. CALL PHY SICIAN. INHALE: MOVE TO FRESH AIR.
GIVEOXYGEN/ARTIFICIAL RESPIRATION, IF NEEDED, CALL PHYSICIAN.
OTHER: REFERRAL TO PHYSICIAN IS RECOMMENDED IF THERE IS ANY
QUESTION ABOUT SERIOUSNESS OF ANY INJURY.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:170F,77C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:DECOMPOSITION AND COMBUSTION PRODUCTS MAY
BE TOXIC.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SPILLAGE BY ABSORBING IN ABSORBENT
MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:WARNING COMBUSTIBLE. KEEP AWAY FROM
HEAT AND FLAME. AVOID CONTACT W/EYES/SKIN/CLOTHES. AVOID BREATHING
VAPOR/MIST. KEEP CONTAINER CLOSED. USE W/*
Other Precautions:*ADEQUATE VENTILATION. WASH THOROUGHLY AFTER
HANDLING. NUISANCE DUST MAY BE GENERATED WHEN SANDING OR SAWING
CURED MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED ORGANIC VAPOR CARTRIDGE
RESPIRATOR WHEN VAPOR/MIST EXPOSURE IS LIKELY.
Ventilation:GENERAL MECHANICAL AND LOCAL EXHAUST IN ACCORDANCE WITH
ACGIH RECOMMENDED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Pres:9.57 @ 55C
Spec Gravity:1.88-1.96;WTR=1
Solubility in Water:INSOLUBLE
Appearance and Odor:BLUE OPAQUE LIQUID, WITH SLIGHT ETHEREAL ODOR
Percent Volatiles by Volume:NEGLIG
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS AND BASES.
Stability Condition to Avoid:EXCESSIVE HEAT FOR PROLONGED PERIODS OF
TIME.
Hazardous Decomposition Products:COMBUSTION MAY FORM TOXIC MATERIALS,
SUCH AS CARBON DIOXIDE, CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT QUALIFIED LOCAL OR CORPORATE PERSONNEL
FOR METHOD THAT WILL COMPLY WITH LOCAL, STATE AND FEDERAL HEALTH
AND ENVIRONMENTAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ALKYD,FLAT,WHITE 37778
CAGE:60189
CAGE:60189
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA (PETROLEUM SPIRITS OR BENZIN)
CAS:8030-30-6
RTECS #:SE7555000
Fraction by Wt: 31%
OSHA PEL:100 PPM
===================== Hazards Identification =====================
Effects of Overexposure:IRRITATION OF EYES AND SKIN.IRRITATION OF
RESPIRATORY TRACT HEADACHE OR DIZZY.
======================= First Aid Measures =======================
First Aid:SKIN/EYES: FLUSH WITH PLENTY OF WATER. INHAL:REMOVE TO FRESH
AIR. IF IRRITATION PERSISTS,CALL DR.
===================== Fire Fighting Measures =====================
Flash Point:50.6/123 CC
Lower Limits:1.0
Upper Limits:6.0
Extinguishing Media:USE CLASS B EXTINGUISHERS (CARBON DIOXIDE,DRY
CHEM.,FOAM)
Fire Fighting Procedures:USE WATER TO COOL CLOSED CONTAINERS & PREVENT
AUTOIGNITION.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED AND
ISOLATE FROM SOURCES OF IGNITION.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION(FLAMES,HOT
SURFACES,ELECTRICAL,STATIC OR FRICTIONAL SPARKS)AVOID BREATHING
VAPORS.VENTILATE AREA.REMOVE WITH INERT ABSORBENT AND NON-SPARKING
TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE AT ELEVATED TEMP.KEEP
AWAY FROM OPEN FLAME AND SPARKS.
Other Precautions:DO NOT TAKE INTERNALLY.CONTAINERS SHOULD BE GROUNDED
WHEN POURING.AVOID PROLONGED OR REPEATED CONTACT WITH SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:BUREAU OF MINES APPROVED CHEM/MECH FILTER
RESPIRATOR
Ventilation:LOCAL EXHAUST
Other Protective Equipment:PREVENT PROLONGED SKIN CONTACT WITH
CONTAMINATED CLOTHING.
Supplemental Safety and Health
CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.DO NOT APPLY
TO HOT SURFACES.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:174.4/346
Vapor Pres:4
Vapor Density:5.3
Spec Gravity:1.37
Evaporation Rate & Reference:BUAC=1: 0.05
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE LIQUID,MILD ALIPHATIC ODOR.
Percent Volatiles by Volume:57
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO,CO*2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL,STATE AND
FEDERAL REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: 876-021-309, IMPROVED TREMSEAL GP
Cage: TRMC0
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: TRMC0
Cage: 94529
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: EYE/SKIN:CAN CAUSE IRRIT. INHAL:CAN CAUSE HDCH, DIZZ,
NAUS, DROWS, IRRIT TO RESP SYS. INGEST:CAN CAUSE GI IRRIT. CHRONIC:RPTS HAVE
ASSOC RPTD/PRLNGD OCCUP OVEREXP TO SOLVS W/PERM BRAIN/ NERV SYS DMG.
INTENTIONAL MISUSE BY DELIB CONC & INAHLING CONTENTS MAY BE
HARMFUL/FATAL. PRLNGD/RPTD OVEREXP TO FREE (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: SILICA, CRYSTALLINE (QUARTZ):ANTICIPATED TO BE
CARCINOGEN. (NTP), GROUP 2A (IARC).
Signs And Symptions Of Overexposure: HLTH HAZ:CRYSTALLINE SILICA DUST ABOVE TLV
MAY CAUSE SCARRING OF LUNGS W/COUGH & SHORTNESS OF BREATH. A DELAYED LUNG
INJURY, SILICOSIS, MAY RESULT FROM INHAL OF FREE SILICA. PRLNGD/RPTD OVEREXP
TO TOL UENE CAUSED LIVER/KIDNEY DMG IN LAB ANIMALS. BASED ON ANIMAL
EXPERIMENTS, TOLUENE MAY BE CARDIAC SENSIT (SUPP DATA)
Medical Cond Aggravated By Exposure: EXPOSURE TO TOLUENE CAN AGGRAVATE PRE-
EXISTING EYE, SKIN AND RESPIRATORY DISORDERS AND ANEMIA.
First Aid: SKIN:WASH THOROUGHLY WITH HAND CLEANER FOLLOWED BY SOAP & WATER.
IF IRRITATION, RASH OR OTHER DISORDERS DEVELOP, GET MD IMMEDIATELY. EYE:FLUSH
IMMEDIATELY W/RUNNING WATER FOR AT LEAST 15 MINUTES, LIFT ING UPPER/LOWER
LIDS OCCASIONALLY. GET MD IMMEDIATELY. INGEST: GET MD IMMEDIATELY. INHAL:MOVE
TO FRESH AIR. AVOID FURTHER OVEREXPOSURE. IF SYMPTOMS PERSIST, GET MD
IMMEDIATELY.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE SOURCES OF IGNITION IMMEDIATELY. VENTILATE TO
REDUCE AIRBORNE CONTAMINANT CONCENTRATION BELOW EXPOSURE LIMIT. ABSORB SPILL
IN SAND, EARTH OR OTHER SUITABLE MATERIAL. TRANSFER TO APPROPRIATE CON TAINER
FOR DISPOSAL.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
Handling And Storage Precautions: STORE UNDER NORMAL WAREHOUSE CONDITIONS BELOW
80F. PVNT INHALATION OF VAPOR, INGESTION & CONTACT WITH SKIN AND EYES.
KEEP CNTNR CLSD WHEN NOT IN USE.
Other Precautions: PRECAUTIONS ALSO APPLY TO EMPTIED CONTAINERS. PERSONAL
PROTECTIVE EQUIPMENT MUST BE WORN DURING MAINTENANCE OR REPAIR OF CONTAM
MIXER, REACTOR OR OTHER EQUIPMENT. FOR INDUSTRIAL USE ONLY. KEEP OUT OF
REACH OF CHILDREN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: IF WATER FOG IS INEFFECTIVE, USE CARBON DIOXIDE, DRY
CHEMICAL OR FOAM.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NEVER USE A WELDING OR CUTTING TORCH ON OR NEAR
CONTAINER (EVEN EMPTY). PRODUCT, RESIDUE OR VAPOR MAY IGNITE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: WEAR APPROPRIATE, PROPERLY FITTED NIOSH/MSHA APPROVED
RESPIRATOR WHEN AIRBORNE CONTAMINANT LEVEL(S) EXCEED EXPOS LIMITS INDICATED.
FOLLOW RESPIRATOR MANUFACTURERS DIRECTIONS FOR RESPIRATOR USE.
Ventilation: USE LOCAL EXHAUST WHEN GENERAL VENT IS NOT SUFFICIENT TO KEEP
AIRBORNE CONTAM CNC BELOW EXPOS LIMIT IN INGREDS SECTION.
Other Protective Equipment: TYPICAL FULL COVER CLOTHING.
Work Hygienic Practices: CHANGE SOILED WORKCLOTHES FREQUENTLY. CLEAN HANDS
Supplemental Safety and Health: EFTS OF OVEREXP:& MAY CAUSE BIRTH DEFECTS
OR OTHER REPROD ABNORM. OVEREXP TO MINERAL SPIRITS CAN ADVERSELY AFFECT LUNG,
CNS OR CARDIAC SYS. PRLNGD/RPTD EXPOS CAUSED KIDNEY DMG IN MALE RATS.
NOTICE:(TO LUENE CAS# 108-88-3) APPEARS ON NAVY LISTING OF OCCUP REPROD HAZS.
SEEK CONSULTATION FROM APPROP HLTH
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
Vapor Density: >1
Spec Gravity: 1.27
Evaporation Rate & Reference: >1 (ETHER=1)
Solubility in Water: NEGLIGIBLE
Appearance and Odor: PASTE WITH SLIGHT ODOR
Percent Volatiles by Volume: ING 14
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: BY IGNITION:HYDROCYANIC ACID.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 36738
Product ID: 876-021-309, IMPROVED TREMSEAL GP
Review Date: 01/12/1993
Multiple KIT Number: 0
Review IND: Y
Additional Data: NOT REGULATED FOR TRANSPORTATION
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: 876-021-309, IMPROVED TREMSEAL GP
Cage: TRMC0
Company Name: TREMCO
Street: 3735 GREEN RD
Zipcode: 44122
Label Required IND: Y
Date Of Label Review: 06/23/1992
Status Code: C
Label Date: 06/23/1992
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE:EYE AND SKIN CONTACT MAY CAUSE IRRITATION.INHAL
MAY CAUSE HEADACHE,DIZZ,NAUSEA,DROWSINESS&IRRIT OT RESPIR
SYSTEM.INGESTION MAY CAUSE GI IRRIT.CHRONIC:CANCER HAZ.CRYSTALLINE SILICA
QUARTZ ISLISTE D AS A CARCINOGEN(FP N).REPEATED AND PROLONGED SOLVENT
OVEREXPOSURE IS ASSOC WITH PERMANENT BRAIN&NERV SYS DMG.PRLNGED/RPTD
OVEREXP TO CRYSTALLINE SILICA DUST MAY CAUSE SCARRING OF LUNGS,DELAYED LUNG
INJURY/SILICOSIS.CNTNS TOLUENE,A REPROD HAZ.TOLUENE CAUSES LIVER & KIDNEY
DMG,BIRTH DEFECTS,REPROD ABNORM&CARDIAC SENSIT IN ANIMALS.OVEREXP TO
MINERAL SPIRITS MAY ADVERSELY AFFECT LUNGS,CNS OR CARDIAC SYS. TOLUENE
APPEARS ON THE NAVY REPROD. HAS LST.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BODY MOISTURIZING LOTION
CAGE:61071
CAGE:61071
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: NONE KNOWN. CHRONIC: NONE
KNOWN.
Explanation of Carcinogenicity:NOT CARCINOGENIC.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: NONE. EYES: FLUSH WITH WATER FOR 15 MIN. CONSULT
A PHYSICIAN. SKIN: NONE. INGESTION: DRINK LARGE AMOUNTS OF WATER,
CONSULT A PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:NFPA CLASS B (CARBON DIOXIDE, DRY CHEMICAL, FOAM)
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE WITH WATER.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT FREEZE.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED.
Ventilation:NONE..
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:NONE.
Supplemental Safety and Health
NONE.
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Density:>AIR
Spec Gravity:0.9604
Solubility in Water:PARTIAL
Appearance and Odor:PINK LIQUID, HERBAL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL LOCAL, STATE AND
FEDERAL REGULATIONS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:KONIC TONER 4345 PC/UA 947-540 500G
CAGE:89431
CAGE:89431
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE ACRYLIC RESIN
Ingred Name:COLUMBIA CARBON, CARBON BLACK, LAMPBLACK, BLACK PEARLS
(IARC GROUP 2B) - *98-2*
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 7-12%
Other REC Limits:3.5 MG/CUM (NIOSH)
OSHA PEL:3.5 MG/CUM
ACGIH TLV:3.5 MG/CUM
Ingred Name:WAX-1
Ingred Name:WAX-3
Ingred Name:AMORPHOUS SILICA GEL, SILICON DIOXIDE *98-2*
CAS:7631-86-9
Fraction by Wt: 0.5-1.5%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): >5000 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: MINIMAL RESPIRATORY TRACT
IRRITATION MAY OCCUR. PROLONGED EXPOSURE OF EXCESSIVE DUSTS MAY
CAUSE LUNG DAMAGE.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER. SKIN: WASH W/WATER & MILD
SOAP. INGESTION: WASH OUT MOUTH W/WATER. DRINK 1-2 GLASSES OF
WATER. INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, FOAM
Fire Fighting Procedures:WEAR SCBA & PROTECTIVE CLOTHING TO PREVENT
CONTACT W/SKIN & EYES. IF FIRE IS IN MACHINE, TREAT AS AN ELECTRIC
FIRE, DON'T USE WATER/FOAM.
Unusual Fire/Explosion Hazard:COMBUSTIBLE POWDER. DUST AT SUFFICIENT
CONCENTRATIONS CAN FORM EXPLOSIVE MIXTURES W/AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. MINIMIZE RELEASE OF
PARTICULATES. STOP LEAK W/O RISK. VACUUM/SWEEP MATERIAL, PLACE IN A
BAG, HOLD FOR DISPOSAL. USE VACUUM W/HIGH EFFICIENCY PARTICULATE
AIR FILTER & SHOULD BE ELECTRICALLY BONDED & GROUNDED TO DISIPATE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN A COOL & DRY PLACE. KEEP AWAY FROM OXIDIZERS & IGNITION SOURCES.
KEEP OUT OF REACH OF CHILDREN.
Other Precautions:AVOID DUST GENERATION, DON'T SWEEP DRY. AVOID
PROLONGED INHALATION OF EXCESSIVE DUST & CONTACT W/EYES. THIS
MATERIAL IS CAPABLE OF CREATING A DUST EXPLOSION. KEEP AWAY FROM
HEAT/SPARKS/FLAME.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER NORMAL CONDITIONS. FOR USE
OTHER THAN IN NORMAL OPERATING PROCEDURES SUCH AS IN THE EVENT OF
LARGE SPILL, RESPIRATOR MAY BE REQUIRED.
Ventilation:NOT REQUIRED UNDER NORMAL CONDITIONS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:266F
Spec Gravity:1.1
Solubility in Water:INSOLUBLE
Appearance and Odor:FINE BLACK POWDER W/SLIGHT MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS
Stability Condition to Avoid:TEMPS >392F, HEAT, SPARKS, FLAME
Hazardous Decomposition Products:CO, CO2, SMOKE
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T THROW AWAY THE TONER CARTRIDGE INTO THE
FIRE. DISPOSE OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:504-510 COLORLITH
Preparer's Name:DICK KARBO
CAGE:KMADD
CAGE:KMADD
============= Composition/Information on Ingredients =============
Ingred Name:BARIUM COMPOUNDS
Fraction by Wt: 23%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED CONTACT W/SKIN/EYES CAN
CAUSE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMEDIATELY W/WATER. SKIN: WASH AFFECTED AREA
W/SOAP & WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>200F
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: WIPE UP & STORE WIPERS IN UNDERWRITERS
APPROVED CONTAINERS. LARGE: SCOOP MATERIAL INTO SEALABLE
CONTAINERS. WIPE UP REMAINDER & STORE WIPERS IN UNDERWRITERS
APPROVED CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS.
Other Precautions:AVOID CONTACT W/SKIN, EYES & CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS REQUIRED
Ventilation:LOCAL EXHAUST
Work Hygienic Practices:WASH AFTER USE. REMOVE/LAUNDER CONTAMINATED
CLOTHING BEFORE REUSE. DON'T CONSUME FOOD/BEVERAGE WHERE PRODUCT IS
USED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:470-610F
Evaporation Rate & Reference:SLOWER THAN WATER
Solubility in Water:INSOLUBLE
Appearance and Odor:OILY
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:23002, HISTOSOLVE, XYLENE SUBSTITUTE
CAGE:17602
CAGE:17602
============= Composition/Information on Ingredients =============
Ingred Name:ISOALKANES C9-C12
CAS:90622-57-4
= Wt:100.
===================== Hazards Identification =====================
LD50 LC50 Mixture:NO DATA PROVIDED BY MANUFACTURER
Routes of Entry: Inhalation:YES Skin:UNKNOWN Ingestion:YES
Health Hazards Acute and Chronic:ACUTE: EYE: SPLASHES AND HIGH
CONCENTRATIONS OF VAPORS MAY CAUSE IRRITATION. SKIN: MAY CAUSE
IRRITATION. INHALATION: INHALATION OF VAPORS IN HIGH CONCENTRATIONS
MAY IRRITATE MUCOUS MEMBRANES. INGESTIO N: MAY IRRITATE THE
GASTROINTESTINAL TRACT AND CAUSE SYMPTOMS AS MENTIONED UNDER
INHALATION. LONG TERM: PROLONGED OR FREQUENT EXPOSURE TO VAPORS OF
VOC'S MAY RESULT IN DAMAGE TO LIVER, KIDNEYS, BLOOD OR CENTRAL
NERVOUS SYSTEM (BRAIN DAMAGE).
Explanation of Carcinogenicity:NO DATA PROVIDED BY MANUFACTURER
Effects of Overexposure:EYE: REDNESS. SKIN: REDNESS. INHALATION:
HEADACHE, NAUSEA, VOMITING, DIZZINESS AND UNCONSCIOUSNESS.
INGESTION: HYDROCARBONS ARE HARMFUL AND MAY CAUSE LUNG DAMAGE IF
SWALLOWED. BE AWARE THAT SYMPTOMS ( DYSPNEA) CAN DEVELOP SEVERAL
HOURS AFTER EXPOSURE.
Medical Cond Aggravated by Exposure:NO DATA PROVIDED BY MANUFACTURER
======================= First Aid Measures =======================
First Aid:GENERAL: IF ANY SYMPTOMS OCCUR: SEEK MEDICAL ADVICE. SHOW
THIS MATERIAL SAFETY DATA SHEET TO A PHYSICIAN OR EMERGENCY WARD.
EYE: FLUSH WITH WATER OR PHYSIOLOGICAL SALT WATER FOR 15 MINUTES.
REMOVE CON TACT LENSES. IF IRRITATION PERSISTS: SEEK MEDICAL
ADVICE. CONTINUE FLUSHING ON THE WAY. SKIN: REMOVE CONTAMINATED
CLOTHING & WASH SKIN WITH WATER & MILD SOAP. FLUSH 15 MINUTES WITH
WATER. RUB THE SKIN WITH A HAND LOTION. INHALATION: REMOVE TO
FRESH AIR. KEEP AT REST. IF SYMPTOMS PERSISTS: SEEK MEDICAL ADVICE.
ADMINISTER OXYGEN OR ARTIFICIAL RESPIRATION AS NEEDED. INGESTION:
RINSE MOUTH & DRINK PLE NTY WATER. DO NOT PROVOKE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point:30 TO 40 DEG C
Autoignition Temp:=293.C, 559.4F
Lower Limits:0.6%
Upper Limits:7%
Extinguishing Media:USE DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:WHEN EXTINGUISHING FIRES USE SELF CONTAINED
BREATHING APPARATUS. REMOVE CONTAINERS IF POSSIBLE. APPLICATION
OF WATER FOG/SPRAY WILL AID IN KEEPING FIRE-EXPOSED MATERIALS COOL.
Unusual Fire/Explosion Hazard:IN CASE OF FIRE THE PRODUCT MAY FORM
HAZARDOUS DECOMPOSITION PRODUCT SUCH AS OXIDES OF CARBON. VAPORS
ARE HEAVIER THAN AIR AND CAN TRAVEL ALONG THE GROUND TO AN IGNITION
SOURCE AND FLASH BACK TO VAPOR SOURCE.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP WITH A NON FLAMMABLE ABSORBENT
MATERIAL FLUSH WITH WATER. DO NOT EMPTY INTO DRAINS. IF THE PRODUCT
CONTAMINATES LAKES, RIVERS OR SEWAGES, INFORM APPROPRIATE
AUTHORITIES IN ACCORDANCE WITH LOC AL REGULATIONS. PROVIDE FOR
SUFFICIENT VENTILATION/RESPIRATORY PROTECTION. REMOVE SOURCES OF
IGNITION.
Neutralizing Agent:NO DATA PROVIDED BY MANUFACTURER
======================Handling and Storage ======================
Handling and Storage Precautions:SAFE STORAGE: AT ROOM TEMPERATURE AND
WELL VENTILATED AND AWAY FROM STRONG OXIDIZERS. KEEP CONTAINER
TIGHTLY CLOSED WHEN NOT IN USE. STORE IN A FLAMMABLE LIQUID STORAGE
AREA.
Other Precautions:NO DATA PROVIDED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN CASE OF BADLY VENTILATED AREAS USE AN
APPROVED MASK WITH A GAS FILTER A WHEN RISK OF INHALING VAPORS.
Ventilation:PROVIDE ADEQUATE VENTILATION
Other Protective Equipment:THERE SHALL BE ACCESS TO WATER
Work Hygienic Practices:AVOID BREATHING OF VAPORS AND CONTACT WITH
SKIN, EYES AND CLOTHES. WASH WITH WATER AND SOAP AFTER WORK. DO NOT
SMOKE.
Supplemental Safety and Health
FLAMMABLE, DO NOT USE NEAR FIRE OR SPARKS.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:154 TO 177 DEG C
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR COLORLESS LIQUID, CHARACTERISTIC ODOF OF
HYDROCARBONS
================= Stability and Reactivity Data =================
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:VAPORS CAN BE IGNITED BY A SPARK, A HOT
SURFACE OR A GLOW. AVOID SOURCES OF IGNITION SUCH AS HEAT, SPARKS
AND FLAMES
Hazardous Decomposition Products:COMBUSTION MAY PRODUCE OXIDES OF
CARBON.
=================== Toxicological Information===================
Toxicological Information:THE PRODUCT WAS CLASSIFIED IN TOXICOLOGICAL
TERMS ON THE BASIS OF THE RESULTS OF THE CALCULATION PROCEDURE
OUTLINED WITHIN GENERAL DIRECTIVE ON PREPARATIONS (88/379/EEC).
===================== Ecological Information =====================
Ecological:THE HYDROCARBONS ARE VOLATILE AND EVAPORATE FROM THE WATER
SURFACE. THE HYDROCARBONS ARE INHERENTLY BIODEGRADABLE ACCORDING TO
OECD GUIDELINES. DO EMPTY INTO WATERS OR DRAINS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE ACCORDING TO LOCAL, STATE OR
NATIONAL LEGISLATION. DISPOSE OF THROUGH AUTHORITY FACILITIES OR
PASS TO CHEMICAL DISPOSAL COMPANY.EWC-CODE: 160503
=================== MSDS Transport Information ===================
Transport Information:ADR/RID (RAOD/RAIL): CLASS: 3. ITEM NO.: 31.
LETTER: C. UN NO.: 3295. PROPER SHIPPING NAME: HYDROCARBONS,
LIQUID, N.O.S. (ISOALKANES C9-12). SEA (IMDG): IMDG CLASS: 3. IMDG
PAGE NO.: 3352. UN NO.: 329 5. MFAG: 310. EMS: 3-07. PACK. GROUP:
III.
===================== Regulatory Information =====================
SARA Title III Information:NO DATA PROVIDED BY MANUFACTURER
Federal Regulatory Information:NO DATA PROVIDED BY MANUFACTURER
State Regulatory Information:NO DATA PROVIDED BY MANUFACTURER
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:138 6713 MONOCOMPONENT 95 TONER 600 GRAMS
CAGE:EO274
CAGE:EO274
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE ACRYLATE COPOLYMER *94-4*
CAS:23153-46-2
Fraction by Wt: 45-55%
Ingred Name:IRON OXIDE, MAGNETITE *94-4*
CAS:1317-61-9
Fraction by Wt: 40-50%
Ingred Name:SALICYLIC ACID CHROMIUM CHELATE*94-4*
CAS:72869-85-3
Fraction by Wt: 1%
OSHA PEL:0.5 MG/CUM (CR)
ACGIH TLV:0.5 MG/CUM (CR)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, REMOVE TO FRESH AIR. EYES: ANY
MATERIAL THAT CONTACTS THE EYE SHOULD BE WASHED OUT IMMEDIATELY
W/WATER. SKIN: WASH W/SOAP & WATER. INGESTION: DRINK 1-2 GLASSES OF
WATER. OB TAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, CO2, DRY CHEMICAL
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:POWDERED MATERIAL MAY FORM EXPLOSIVE
DUST-AIR MIXTURES.
================== Accidental Release Measures ==================
Spill Release Procedures:DON'T USE A VACUUM CLEANER TO CLEAN UP
POWDERED TONERS. THE VERY FINE PARTICLES CAN CAUSE A
FIRE/EXPLOSION. SWEEP MATERIAL ONTO PAPER & PLACE IN A FIBER
CARTON. CLEAN SURFACE THOROUGHLY TO REMOVE RESI DUAL CONTAMINATION.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. USE W/ADEQUATE
VENTILATION.
Other Precautions:AVOID BREATHING DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED
Ventilation:GOOD VENTILATION (TYPICALLY 4-6 ROOM VOLUMES PER HOUR)
Other Protective Equipment:WASHING FACILITIES.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
SALMONELLA TYPHIMURIUM ASSAY (AMES TEST): NEGATIVE.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:212-302F
Vapor Pres:NEGLIGIBLE
Spec Gravity:1.4-1.6
Evaporation Rate & Reference:(N-BU AC =1): NEGLIGIBLE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:SOLID BLACK POWDER W/SLIGHT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:CO2, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:CAN BE INCINERATED WHEN IN COMPLIANCE W/LOCAL
REGULATIONS. CONTACT W/A LICENSED CHEMICAL DISPOSAL AGENCY.
DISCHARGE, TREATMENT/DISPOSAL MAY BE SUBJECT TO NATIONAL,
STATE/LOCAL LAWS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MORTAR MIX 94 STUCCO AND BULK
Preparer's Name:N. CALLISON & J. ALARCON
CAGE:JO233
CAGE:JO233
============= Composition/Information on Ingredients =============
Ingred Name:CEMENT
Fraction by Wt: 20-30%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MORTAR SAND
Fraction by Wt: 70-75%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CLAY
Fraction by Wt: 0-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
OSHA PEL:N/K
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:SPILL PROC: MAINTAIN, CLEAN & FIT TEST RESPS I/A/W OSHA
REGS. MAINTAIN & TEST VENT & DUST COLLECTION EQUIP. WASH (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: OR VACUUM CLOTHING WHICH HAS BECOME DUSTY.
RTECS #:9999999ZZ
Ingred Name:OTHER PRECS: 1926.59 & 1928.21 & STATE & LOCAL WORKER OR
COMMUNITY "RIGHT TO KNOW" LAWS & REGS. MFR RECOMMENDS (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: SMOKING BE PROHIBITED IN ALL AREAS WHERE RESPS MUST
BE USED. WARN EMPLOYEES (& CUSTOMERS-USERS IN CASE OF (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: RESALE) BY POSTING & OTHER MEANS, OF THE HAZARD &
OSHA PRECAUTIONS TO BE USED. PROVIDE TRAINING FOR (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: EMPLOYEES ABOUT OSHA PRECAUTIONS. SEE ALSO ASTM
STANDARD PRACTICE E1132-86, "STANDARD PRACTICE FOR (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: HEALTH REQUIREMENTS RELATING TO OCCUPATIONAL
EXPOSURE TO QUARTZ DUST."
RTECS #:9999999ZZ
Ingred Name:RESP PROT: FILTER RESP. ANY SUPPLIED-AIR RESP. ANY SCBA. UP
TO 50 X PEL: HIGH EFFICIENCY PARTICULATE FILTER (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: RESP W/FULL FACEPIECE. ANY SUPPLIED-AIR RESP W/FULL
FACEPIECE, HELMET/HOOD. ANY SCBA W/FULL FACEPIECE. (ING 14)
RTECS #:9999999ZZ
Other REC Limits:/K
Ingred Name:ING 13: UP TO 500 X PEL: POWERED AIR-PURIFYING RESP W/HIGH
EFFICIENCY PARTICULATE FILTER. TYPE C SUPPLIED-AIR (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: RESP OPERATED IN PRESS-DEMAND OR OTHER POSITIVE
PRESS OR CONTINUOUS-FLOW MODE. GREATER THAN 500 X PEL (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: OR ENTRY & ESCAPE FROM UNKNOWN CONCS: SCBA W/FULL
FACEPIECE OPERATED IN PRESS-DEMAND OR OTHER POSITIVE (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: MODE. COMBINATION RESP WHICH INCLUDES TYPE C
SUPPLIED-AIR RESP W/FULL FACEPIECE OPERATED IN PRESS-DEMAND(ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17: OR OTHER POSITIVE PRESS CONTINUOUS-FLOW MODE &
AUXILIARY SCBA OPERATED IN PRESS-DEMAND OR OTHER POSITIVE(ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: PRESSURE MODE. ONLY NIOSH APPROVED EQUIP SHOULD BE
USED (SEE 29 CFR 1910.34) SEE ALSO ANSI STD Z88.2- (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19; 1980 "PRACTICES FOR RESPIRATORY PROTECTION."
RTECS #:9999999ZZ
Ingred Name:VENT: DUST TO THE PEL. SEE ACGIH "INDUSTRIAL VENTILATION, A
MANUAL OF RECOMMENDED PRACTICE," LATEST EDITION.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:CONCRETE MASONRY PRODUCTS MAY RELEASE
RESPIRABLE CRYSTALLINE QUARTZ DURING USE. PROLONGED EXPOSURE TO
RESPIRABLE CRYSTALLINE QUARTZ MAY CAUSE DELAYED (CHRONIC) LUNG
INJURY (SILICOSIS). ACUTE OR RAPIDL Y DEVELOPING SILICOSIS MAY
OCCUR IN A SHORT PERIOD OF TIME IN HEAVY EXPOSURE. SILICOSIS IS A
FORM OF (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ: IARC MONO,
VOL 68, 1997:GROUP 1. NTP 7TH ANNUAL REPORT ON CARCINS, 1994:ANTIC
TO BE CARCIN.
Effects of Overexposure:HLTH HAZ: DISABLING PULMONARY FIBROSIS WHICH
CAN BE PROGRESSIVE AND MAY LEAD TO DEATH. SIGNS AND SYMPTOMS OF
EXPOSURE: UNDUE BREATHLESSNESS, WHEEZING, COUGH AND SPUTUM
PRODUCTION.
Medical Cond Aggravated by Exposure:PRE-EXISTING LUNG DISEASES SUCH AS
EMPHYSEMA OR ASTHMA. PULM FUNC MAY BE REDUCED BY INHAL OF
RESPIRABLE CRYSTALLINE SILICA. ALSO LUNG SCARRING PRDCED BY SUCH
INHAL MAY LEAD TO PROGRESSIVE (SUPDAT)
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMEDIATELY . SKIN: FLUSH W/COPIOUS AMOUNTS
OF WATER. CALL MD . EYES: IMMEDIATELY FLUSH GENEROUSLY W/WATER FOR
AT LEAST 15 MINUTES. IF IRRITATION PERSISTS, SEEK MEDICAL ATT
ENTION. INHAL: FOR GROSS INHALATION, REMOVE PERSON IMMEDIATELY TO
FRESH AIR. GIVE ARTIFICIAL RESPIRATION AS NEEDED. SEEK MEDICAL
ATTENTION AS NEEDED.
===================== Fire Fighting Measures =====================
Extinguishing Media:NOT APPLICABLE. MEDIA SUITABLE FOR SURROUNDING FIRE
.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:USE DUSTLESS SYSTEMS FOR HANDLING, STORAGE &
CLEAN-UP SO THAT AIRBORNE DUST DOES NOT EXCEED PEL. USE ADEQ VENT &
DUST EQUIP. PRACTICE GOOD HOUSEKEEPING. DO NOT PERMIT DUST TO
COLLECT ON WALLS, FLOORS, SILLS, LEDGES, MACHINERY OR EQUIP. (ING
5)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE.
Other Precautions:CUTTING, SANDING OR GRINDING OF MASONRY PRODS MAY
EXPOSE YOU TO RESPIRABLE CRYSTALLINE SILICA. PLEASE REVIEW MSDS
INFO ON PROT EQUIP & CONTROL MEASURES. SEE OSHA HAZ COMMUNICATIN
RULE 29 CFR 1910.1000 , 1915.99, 1917.28, 1918.90, (ING 7)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOWING SPECIFIES TYPE OF RESPS WHICH MAY
PROVIDE RESP PROT FOR CRYSTALLINE SILICA: UP TO 5 X PEL: ANY DUST
RESP. UP TO 10 X PEL: ANY DUST RESP, EXCEPT SINGLE-USE OR
QUARTER-MASK RESP. ANY FUME RESP OR HIGH EFFICIENCY PARTICULATE
(ING 12)
Ventilation:WHEN DRY SAWING/GRINDING CONCRETE MASONRY PRODS, USE
SUFFICIENT LOC EXHST VENT TO REDUCE LEVEL OF RESPIRABLE (ING 21)
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
COVERALLS IF NEEDED TO PREVENT SKIN IRRITATION.
Work Hygienic Practices:AVOID CREATING AND BREATHING DUST.
Supplemental Safety and Health
MED CNDTNS: MASSIVE FIBROSIS OF LUNG WHICH MAY AGGRAVATE OTHER PULM
CNDTNS & DISEASES & WHICH INCRS SUSCEPTIBILITY TO PULM
TUBERCULOSIS. PROGRESSIVE MASSIVE FIBROSIS MAY BE ACCOMPANIED BY
RIGHT HEART ENLARGEMENT, HEART FAILURE & PULM FAILURE. SMOKING
AGGRAVATES EFTS OF EXPOSURE.
================== Physical/Chemical Properties ==================
Spec Gravity:1.6 (H*2O=1)
Solubility in Water:NOT SOLUBLE
Appearance and Odor:ODORLESS SOLID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:MORTAR MIX CAN BE DISPOSED OF AS COMMON WASTE BY
ADDING WATER TO SOLIDIFY THE MIXTURE. MORTAR RESIDUE SHOULD BE
DISPOSED OF IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HI LITE POWDER
CAGE:9K743
CAGE:9K743
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM PERSULPHINATE (OXONE)
Other REC Limits:NONE RECOMMENDED
Ingred Name:MANGANESE(II)SULFATE, MONOHYDRATE
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICA, AMORPHOUS, HYDRATED
CAS:7699-41-4
RTECS #:VV8850000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:20 MPPCF; Z-3
ACGIH TLV:10 MG/M3 TDUST; 9596
Ingred Name:POLY(METHYL VINYL ETHER MALEATE K) GANTREZ MS-955
Other REC Limits:NONE RECOMMENDED
Ingred Name:DYE,GREEN
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:MAY CAUSE IRRITATION.INHAL:MAY
CAUSE RESPIRATORY IRRITATION.INGEST/SKIN:NO DATA ON MSDS.
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of Overexposure:EYE AND RESPIRATORY IRRITATION.
Medical Cond Aggravated by Exposure:MANUFACTURER STATES NONE KNOWN.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH WATER.EYES:FLUSH
WITH WATER FOR 15 MINUTES.INHAL:REMOVE TO FRESH AIR.GIVE OXYGEN OR
ARTIFICIAL RESPIRATION IF NEEDED.INGEST:DO NOT INDUCE VOMITING.GET
PROMP T QUALIFIED MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY.
Fire Fighting Procedures:HMIS SUGGESTS TO USE A SELF-CONTAINED
BREATHING APPARATUS WHENEVER FIGHTING A CHEMICAL FIRE.
Unusual Fire/Explosion Hazard:POTASSIUM PERSULPHINATE IS UNSTABLE OVER
300C(BUT THE SMALL MASS OF THIS ITEM MINIMIZES THE HAZARD).
================== Accidental Release Measures ==================
Spill Release Procedures:ADD WATER.SOAK UP WITH NON-COMBUSTIBLE INERT
ADSORBANT(EG.CLAY);FLUSH DOWN THE DRAIN.
Neutralizing Agent:NOT REPORTED.
======================Handling and Storage ======================
Handling and Storage Precautions:REFRIGERATE.KEEP CONTAINER CLOSED WHEN
NOT IN USE.KEEP AWAY FROM HEAT,SPARKS,FLAMES AND INCOMPATIBLE
MATERIALS.
ACCESS TO AUTHORIZED USERS ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NEEDED IN NORMAL SERVICE.
Ventilation:USE GENERAL DILUTION VENTILATION.
Other Protective Equipment:PROVIDE A LOCAL EYE WASH STATION AND SAFETY
SHOWER.
Work Hygienic Practices:EXECISE GOOD LABORATORY PRACTICES.WASH HANDS
AFTER USE AND BEFORE EATING.
Supplemental Safety and Health
SINCE MFR DOES NOT SPECIFY THE COMPOSITIONAL AMT OF POTASSIUM
PERSULPHONATE,HMIS ASSIGNS HCC OF D2,SINCE THE NATIVE FORM OF THIS
COMPOUND IS REGULATED AS UN1492,5.1,III.
================== Physical/Chemical Properties ==================
HCC:D1
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:VERY HIGH
Solubility in Water:ALL BUT SILICA
Appearance and Odor:WHITE POWDER.ODOR NOT REPORTED.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HYDROGEN PEROXIDE.
Stability Condition to Avoid:TEMPERATURE ABOVE 100C(212F) IN THE
PRESENCE OF 1% ORGANIC MATTER.
Hazardous Decomposition Products:OXYGEN(WHEN IN CONTACT WITH
PEROXIDES).
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:335-089, C-9-83
CAGE:HO411
CAGE:3F871
CAGE:HO411
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL SPIRITS.VP:70 MM HG.
Fraction by Wt: 15.2%
Other REC Limits:500 PPM
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:UNKNOWN Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DEFATTING DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:LIQUID IRRITATING.CAN CAUSE
CONJUNCTIVITIS.SKIN:LIQUID IRRITATING.CAN CAUSE DEFATTING
DERMATITIS.INGESTION:N/K
.INHALATION:ANESTHESIA,HEADACHE.NAUSEA,DIZZINESS,ETC.
Medical Cond Aggravated by Exposure:N/K
======================= First Aid Measures =======================
First Aid:EYE:FLUSH WITH WATER FOR AT LEAST 15
MINUTES.SKIN:N/K.INGESTION:SO NOT INDUCE VOMITING,CONTACT PHYSICIAN
IMMESIATELY.INHALATION:REMOVE VICTIM FROM AREA AND RESTORE
BREATHING IF REQUIRED.
===================== Fire Fighting Measures =====================
Flash Point:104F,40C
Lower Limits:0.77
Upper Limits:N/K
Extinguishing Media:FOAM,CO*2,DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT
Unusual Fire/Explosion Hazard:SURPHUR FORMS EXPLOSION MIXTURE BETWEEN
UPPER & LOWE FLAMMABLE LIMITS,KEEP AWAY FROM HEAT,SPARKS AND OPEN
FLAME.HAZ DECOMP PROD:CO,CO*2.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID OPEN FLAME.SPARKS OR OTHER IGNITION
SOUCES.WEAR ADEQUATE RESPIRATOR PROTECTION,FLUSH WITH WATER TO AN
OPEN,WELL VENTILATED AREA AND REMOVE TO A CONTAINER OR ABSORB WITH
ABSORPTION MATERIAL.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID ALL IGNIT SOURCES.AVOID SPLASH
FILLING.STORE IN COOL,WELL VENT AREAS.PREFERABLY OUTSIDE.
Other Precautions:N/K
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN APPROVED ORGANIC CANISTER MASK OR AIR PACK.
Ventilation:LOCAL AND FENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW LEVEL OF CONCERN
Other Protective Equipment:ELECTRICAL AND MECHANICAL EQUIPMENT SHOULD
BE SPARK PROOF
Work Hygienic Practices:USE GOOD PERSONAL HYGIENE.
Supplemental Safety and Health
N/K
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:300-400F
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/K
Vapor Density:>1 (AIR=1)
Spec Gravity:1.61 (WATER=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:N/K
Appearance and Odor:LIQUID
Percent Volatiles by Volume:31
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ODIDIZING MATERIALS.
Stability Condition to Avoid:OPEN FLAMED AND SPARKS SOURCES
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE.
Conditions to Avoid Polymerization:OPEN FLAMES AND SPARK SOURCES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .DISPOSE OF BY CONTROLLED
BURNING OR REPROCESSING.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DIESEL FUEL,2
Preparer's Name:RON KENNY
CAGE:1CU79
CAGE:1CU79
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHALENE (SARA III)
CAS:91-20-3
RTECS #:QJ0525000
Fraction by Wt: <3.0%
Other REC Limits:NONE SPECIFIED
OSHA PEL:10 PPM/15 STEL
ACGIH TLV:10 PPM/15 STEL; 9192
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:DISTILLATES, HYDROSULFURIZED MIDDLE
CAS:64742-80-9
Fraction by Wt: <100%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 OIL MIST
ACGIH TLV:5 MG/M3 OIL MIST
Ingred Name:PETROLEUM DISTILLATE - STREIGHT RUN MIDDLE
CAS:64741-44-2
RTECS #:LX3296000
Fraction by Wt: <100%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:ALIPHATIC PETROLEUM SOLVENT/KEROSENE
CAS:8008-20-6
RTECS #:OA5500000
Fraction by Wt: <100%
Other REC Limits:NONE SPECIFIED
Ingred Name:LIGHT HYDROCARBON BLEND
CAS:64741-59-9
Fraction by Wt: <100%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE & CHRONIC-EYE:NOT EXPECTED TO
CAUSE SIGNIFICANT IRRITATION.SKIN:MODERATE IRRITANT.MAY CAUSE
PAIN,DISCOLORATION,BLISTERING & DERMATITIS.INHALE:PROLONGED
BREATHING OF VAPORS CAN CAUSE CNS EFFECTS CAUSING
HEADACHE,DIZZINESS,WEAKNESS & LOSS OF APPETITE &
COORDINATION.ORAL:GASTRITIS,LOSS OF CONSCIOUSNESS,LUNG DAMAGE.
Explanation of Carcinogenicity:NIOSH RECOMMENDS THAT WHOLE DIESEL
EXHAUST BE REGARDED AS A "POTENTIAL OCCUPATIONAL CARCINOGEN".
Effects of Overexposure:NOT EXPECTED TO CAUSE SIGNIFICANT EYE
IRRITATION. MODERATE SKIN IRRITANT. MAY CAUSE PAIN, DISCOLORATION,
BLISTERING & DERMATITIS. PROLONGED BREATHING OF VAPORS CAN CAUSE
CNS EFFECTS CAUSING HEADACHE, DIZZINESS, WEAKNESS & LOSS OF
APPETITE & COORDINATION. ORALLY CAN CAUSE GASTRITIS, LOSS OF
CONSCIOUSNESS, LUNG DAMAGE.
Medical Cond Aggravated by Exposure:PRE-EXISTING DERMATITIS MAY BE
AGGRAVATED.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST.SKIN:WASH WITH SOAP
& WATER.EYE:FLUSH WITH WATER FOR 15 MINUTES,HOLDING EYELIDS
OPEN.INHALED:REMOVE TO FRESH AIR & PROVIDE OXYGEN/CPR IF
NEEDED.ORAL:DO NOT IN DUCE VOMITING.IF VOMITING OCCURS,KEEP HEAD
BELOW HIPS TO PREVENT ASPIRATION.CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:125F,52C
Lower Limits:0.6
Upper Limits:7.5
Extinguishing Media:WATER SPRAY, CO2, FOAM/DRY CHEMICAL. WATER SPRAY
MAY BE USED TO KEEP FIRE EXPOSED CONTAINERS COOL & FLUSH SPILLS
AWAY.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS WITH FULL
FACEPIECE OPERATED IN THE POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:FLOWING OIL CAN BE IGNITED BY SELF
GENERATED STATIC ELECTRICITY. FIRE HAZARD IS GREATER AS LIQUID
TEMPERATURE RISES ABOVE 85F.
================== Accidental Release Measures ==================
Spill Release Procedures:THIS MATERIAL IS CONSIDERED TO BE A WATER
POLLUTANT AND RELEASES OF THIS PRODUCT SHOULD BE PREVENTED.
ELIMINATE ALL OPEN FLAMES. STOP SOURCE OF THE LEAK. CONTAIN LIQUID.
CLEAN UP SPILL USING APPROPRIA TE TECHNIQUES SUCH AS ABSORBENT
MATERIALS/PUMPING.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE-STORE IN COOL VENTILATED AREA
AWAY FROM FLAME,SPARKS & HOT SURFACES.KEEP CONTAINER CLOSED.
Other Precautions:USE ONLY IN WELL VENTILATED AREA. DO NOT WELD, HEAT
OR DRILL CONTAINER. EMPTY CONTAINER STILL CONTAIN
HAZARDOUS/EXPLOSIVE VAPOR/LIQUID. DO NOT USE PRESSURE TO EMPTY DRUM
OR EXPLOSION MAY RESULT. TOXIC FUMES MAY ACCUMULATE AND CAUSE
DEATH.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE APPROVED RESPIRATORY PROTECTIVE EQUIPMENT
FOR CLEANING LARGE SPILLS OR ENTRY INTO LARGE TANKS, VESSELS OR
OTHER CONFINED SAPCES.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:REMOVE CONTACT LENSES AND WEAR CHEMICAL
SAFETY GLASSES WHERE CONTACT WITH LIQUID MAY OCCUR.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING THIS
PRODUCT.
Supplemental Safety and Health
USE SPARKS-PROOF TOOLS. MATERIAL MAY BE AT ELEVATED TEMPERATURES AND/OR
PRESSURES. EXERCISE DUE CARE WHEN OPENING BLEEDERS AND SAMPLING
PORTS. KEEP HEAD AWAY FROM CONTAINER WHEN OPENING OR DISPENSING.
DO NOT USE AS A PORTABLE HEATER OR APPLIANCE FUEL.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:<675F,<357C
Vapor Pres:1.6
Vapor Density:8
Spec Gravity:0.87
Evaporation Rate & Reference:0.01 (N-BUTYL ACETATE=1)
Solubility in Water:NIL
Appearance and Odor:CLEAR TO LIGHT AMBER LIQUID. MAY BE DYED RED
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:HIGH HEAT, SPARKS, STATIC ELECTRICITY,
OPEN FLAMES AND OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE CONTAMINATED MATERIALS IN DISPOSABLE
CONTAINERS AND DISPOSE OF IN A MANNER CONSISTENT WITH APPLICABLE
REGULATIONS. CONTACT LOCAL ENVIRONMENTAL OR HEALTH AUTHORITIES FOR
APPROVED DISPOSAL OF THIS MATERIAL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DC-7085, BLACK TONER
CAGE:65678
CAGE:65678
============= Composition/Information on Ingredients =============
Ingred Name:PROPENE, POLYMERS; (POLYPROPYLENE)
CAS:9003-07-4
RTECS #:UD1842000
Ingred Name:STYRENE-ACRYLATE COPOLYMER
CAS:27136-15-8
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 10%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:ORGANIC PIGMENTS CONTAINING INGREDIENTS 3,4, AND 5.
RTECS #:9999999ZZ
Fraction by Wt: 5%
OSHA PEL:1 MG/M3 (MFR)
ACGIH TLV:0.5 MG/M3 (MFR)
Ingred Name:DYE
CAS:109125-51-1
Ingred Name:DYE
CAS:109125-50-0
Ingred Name:DYE
CAS:84179-66-8
Ingred Name:POLYMER RESINS CONTAINING INGREDIENTS 7 & 8.
RTECS #:9999999ZZ
Fraction by Wt: 85%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE IN NORMAL HANDLING AND USE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:MINIMAL RESPIRATORY TRACT IRRITATION MAY OCCUR
AS WITH EXPOSURE TO LARGE AMOUNTS OF ANY NON-TOXIC DUST.
======================= First Aid Measures =======================
First Aid:SKIN: WASH WITH SOAP AND WATER. EYE: FLUSH THOROUGHLY WITH
WATER FOR AT LEAST 15 MIN AND SEEK MEDICAL TREATMENT. INGESTION:
DILUTE STOMACH CONTENTS WITH SEVERAL GLASSES OF WATER AND SEEK
MEDICAL TREAT MENT. INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING
(GIVE O2/ ARTF RESP) .
===================== Fire Fighting Measures =====================
Flash Point:>350F,>177C
Extinguishing Media:IF PRODUCT BECOMES INVOLVED IN A FIRE, USE CARBON
DIOXIDE EXTINGUISHER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . USE CARBON DIOXIDE EXTINGUISHER.
Unusual Fire/Explosion Hazard:NONE UNDER NORMAL STORAGE AND USE
CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP WITH A VACUUM CLEANER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CLOSE CAP TIGHTLY AND STORE IN A COOL,
DRY AND DARK PLACE.
Other Precautions:AVOID COMBUSTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL USE. NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE REQUIRED UNDER NORMAL USE.
Other Protective Equipment:NONE REQUIRED UNDER NORMAL USE.
Work Hygienic Practices:AVOID INHALATION, INGESTION, SKIN OR EYE
CONTACT.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:268F,131C
Spec Gravity:1.1 (H2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:FINE BLACK POWDER, PRACTICALLY ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE IN NORMAL HANDLING AND USE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:134 6675 EKTACOLOR PRIME DEVELOPER REPLENISH MX 1705,PART A
Kit Part:Y
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 70 - 75%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
Ingred Name:DIETHYLHYDROXYLAMINE
CAS:3710-84-7
RTECS #:NC3500000
Fraction by Wt: 10 - 15%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TRIETHANOLAMINE
CAS:102-71-6
RTECS #:KL9275000
Fraction by Wt: 10 - 15%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SUBSTITUTED STILBENE
CAS:82640-05-9
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE. ACUTE- EYE:NO
SPECIFIC HAZARD KNOWN. MAY CAUSE TRANSIENT IRRITATION. SKIN:LOW
HAZARD FOR RECOMMENDED HANDLING. INHALE:EXPECTED TO BE A LOW
HAZARD. ORAL:EXPECTED TO BE A LOW INGESTIO N HAZARD. CHRONIC-
UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:TRANSIENT EYE IRRITATION
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING EYE
PROBLEMS MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:MOVE TO FRESH
AIR. EYES:ANY MATERIAL THAT CONTACTS THE EYE SHOULD BE WASHED OUT
IMMEDIATELY WITH WATER. SKIN:WASH WITH SOAP & WATER. ORAL:DRINK 1-2
GLASSE S OF WATER. SEEK MEDICAL ATTENTION. NEVER GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:100-200F ESTIMAT
Extinguishing Media:USE WATER SPRAY, CARBON DIOXIDE (CO2), ALCOHOL FOAM
OR DRY CHEMICAL. USE WATER SPRAY TO COOL FIRE EXPOSED CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. HAZARDOUS DECOMPOSITION
PRODUCTS MAY BE FORMED.
Unusual Fire/Explosion Hazard:COMBUSTIBLE LIQUID. CONTAINER MAY
RUPTURE. DECOMPOSITION MAY OCCUR.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES. FLUSH TO SEWER WITH
LARGE AMOUNT OF WATER. OTHERWISE, ABSORB SPILL WITH INERT MATERIAL
SUCH AS VERMICULITE, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE.
CLEAN SURFACE THOROUG HLY TO REMOVE RESIDUAL CONTAMINATION.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL PLACE AWAY FROM IGNITION
SOURCES & INCOMPATIBLE MATERIALS. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:COMBUSTIBLE LIQUID. KEEP OUT OF REACH OF CHILDREN.
AVOID EYE CONTACT. USE WITH ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES/HR)
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:EYE BATH, WASHING FACILITIES, SAFETY SHOWER
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
KEY1:C4. KIT CONSISTS OF PART A, PART B AND PART C (PNI: A, B, C).
ECOLOGICAL INFORMATION: A LOW BIOCHEMICAL OXYGEN DEMAND, A LOW
POTENTIAL TO AFFECT AQUATIC ORGANISMS. AFTER DILUTION WITH LARGE
AMOUN T OF WATER, FOLLOWED BY SECONDARY WASTETREATMENT, IT IS NOT
EXPECTED TO CAUSE ADVERSE ENVIRONMENTAL EFFECTS.
================== Physical/Chemical Properties ==================
HCC:C1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:>212F,>100C
Decomp Temp:Decomp Text:356F,180C
Vapor Pres:18 @ 68F
Vapor Density:0.6
Spec Gravity:1.03
pH:11.2
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT YELLOW LIQUID - SLIGHT AMINE ODOR
Percent Volatiles by Volume:70- 75
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:FLAMES, HEAT, TEMPERATURES ABOVE 80C/176F
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL REGULATIONS. FLUSH TO SEWER WITH LARGE
AMOUNT OF WATER, IF PERMITTED.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MAGNETIC PARTICLE VEHICLE CARRIER II, 55 GALLONS
Preparer's Name:BRUCE C. GRAHAM
CAGE:59042
CAGE:37676
CAGE:59042
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL, WHITE; (WHITE MINERAL OIL (PETROLEUM))
CAS:8042-47-5
RTECS #:PY8047000
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN CONTACT:CAN IRRITATE BY REMOVING
NATURAL SKIN OILS ON LONG OR REPEATED EXPOSURES. EYES:MAY CAUSE
IRRITATION. INHAL:NOT SIGNIFICANT AT ROOM TEMPERATURES. WHEN
HEATED, CARRIER II VAPORS MAY CAUSE D IZZINESS & NAUSEA. INGEST:NOT
SIGNIFICANT IN SMALL (MOUTHFUL) AMOUNTS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:SKIN:WASH OFF W/SOAP & WATER. USE SOOTHING LOTION. EYES:RINSE
CAREFULLY UNDER UPPER & LOWER EYELIDS USING PLENTY OF WATER FOR AT
LST 15 MINS. INHAL:REMOVE TO FRESH AIR IF DIZZY/NAUSEATED.
INGEST:DO NO T INDUCE VOMIT. ACCIDENTAL INGEST OF SINGLE MOUTHFUL
IS NOT EXPECTED TO CAUSE SIGNIFICANT HARM. NOTE:IN ALL SEV CASES,
REGIONAL (SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F,>93C
Lower Limits:1%
Upper Limits:6%
Extinguishing Media:CARBON DIOXIDE, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
KEEP CNTNRS COOL W/WATER SPRAY. DO NOT SPRAY DIRECTLY ON BURNING
CARRIER II. IT MAY FLOAT & SPREAD FIRE.
Unusual Fire/Explosion Hazard:DIFFICULT TO IGNITE, BUT WILL BURN
VIGOROUSLY, IF ENGULFED IN FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:MOP UP OR SWEEP UP W/ABSORBENT. IT FLOATS ON
WATER & CAN BE SKIMMED OFF, ITS LOW VAPOR PRESSURE MAY EXEMPT IF
FROM VOC RESTRICTIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING SPRAY MIST. AVOID
REPEATED OR PROLONGED SKIN CONTACT. STORE AWAY FROM HEAT SOURCE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR W/FILTER IF
SPRAYED IN ENCLOSED, UNVENTILATED SPACE.
Ventilation:NONE, UNLESS APPLIED AS SPRAY. USE WHERE VENTILATION WILL
CARRY SPRAY MIST AWAY FROM OCCUPIED AREAS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC:POISON CONTROL CENTER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>455F,>235C
Vapor Pres:<0.1
Vapor Density:HVR/AIR
Spec Gravity:0.82
pH:NEUT
Evaporation Rate & Reference:NEGLIGIBLE
Solubility in Water:0%
Appearance and Odor:CLEAR, COLORLESS LIQUID; OILY ODOR.
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:HEATING ABOVE 200F (93C) IN PRESENCE OF
IGNITION SOURCES.
Hazardous Decomposition Products:SMOKE, SOOT, OXIDES OF CARBON IF
HEATED TO COMBUSTION TEMPERATURES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . AS A NON-HAZARDOUS OILY WASTE, INCINERATE OR SEND TO
WASTE HANDLER WHO CAN BLEND IT INTO SECONDARY FUELS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:NICKEL BASE ALLOY
Preparer's Name:LARRY J SWITAJ
CAGE:COPPE
CAGE:COPPE
CAGE:93932
============= Composition/Information on Ingredients =============
Ingred Name:CARBON, ACTIVATED CARBON, GRAPHITE
CAS:7440-44-0
RTECS #:FF5250100
Fraction by Wt: 0.01-2%
OSHA PEL:10 MG/CUM
ACGIH TLV:10 MG/CUM
Ingred Name:MANGANESE *96-3*
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 0.01-5%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM (DUST)
Ingred Name:IRON *96-3*
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: 0.01-44%
Ingred Name:BORON *96-3*
CAS:7440-42-8
RTECS #:ED7350000
Ingred Name:SILICON * 96-3 *
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: 0.01-2%
ACGIH TLV:10 MG/CUM
Ingred Name:TITANIUM, DRY POWDER *96-3*
CAS:7440-32-6
RTECS #:XR1700000
Fraction by Wt: 0.01-5%
Ingred Name:COBALT (ANIMAL CARCINOGEN BY IARC - GROUP 2B) *96-3*
CAS:7440-48-4
RTECS #:GF8750000
Fraction by Wt: 0.01-13%
Other REC Limits:0.05 PPM
OSHA PEL:0.1 MG/CUM
ACGIH TLV:0.05 MG/CUM
Ingred Name:TANTALUM
CAS:7440-25-7
RTECS #:WW5505000
Fraction by Wt: 0.01-5%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:COLUMBIUM, NIOBIUM *96-3*
CAS:7440-03-1
Fraction by Wt: 0.01-5%
Other REC Limits:5 MG/CUM
Ingred Name:CHROMIUM METAL, CHROMIUM, CHROME (CARCINOGEN BY NTP; IARC
GROUP 3) *96-3*
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 0.01-48%
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:YTTRIUM
CAS:7440-65-5
RTECS #:ZG2980000
Fraction by Wt: <1%
OSHA PEL:1 MG/CUM
ACGIH TLV:1 MG/CUM
Ingred Name:TUNGSTEN (INSOLUBLE), WOLFRAM *96-3*
CAS:7440-33-7
RTECS #:YO7175000
Fraction by Wt: <5%
ACGIH TLV:5 MG/CUM
Ingred Name:MOLYBDENUM (SOLUBLE COMPOUND)
CAS:7439-98-7
RTECS #:QA4680000
Fraction by Wt: 0.01-16%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:COPPER (DUST & MIST), BRONZE POWDER *96-3*
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 0.01-45%
Other REC Limits:1 MG(CU)/M3 (DUST)
OSHA PEL:0.1 MG(CU)/M3 (FUME)
ACGIH TLV:0.2 MG/M3 (FUME)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ALUMINUM*96-3*
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: <5%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DUST/FUME MAY CAUSE IRRITATION TO THE
EYES, NOSE/THROAT. TANTALUM DUST & FUME CAN BE TOXIC WHEN INHALED.
ALUMINUM OXIDE FUME/SILICON MAY CAUSE BENIGN PNEUMOCONIOSIS.
COBALT: LUNG INFLAMMATION, DAMAGE/ FIBROSIS. CHROMIUM ENTERS BODY
THROUGH INHALATION/INGESTION/SKIN.COPPER: INHALATION CAUSES
NOSE/THROAT IRRITATION.(SUPP)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:METALLIC TASTE IN MOUTH, FLU-LIKE SYMPTOMS,
IRRITATION, FEVER, DIFFICULTY BREATHING, EDEMA.
Medical Cond Aggravated by Exposure:PREDISPOSITION TO RESPIRATORY
DISORDERS MAY BE ADVERSELY AFFECTED BY PARTICLES/RESPIRATORY
IRRITANTS GENERATED DURING THE MFG PROCESS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT
GIVE OXYGEN. SKIN: WASH W/MILD SOAP & RINSE W/WARM WATER. EYES:
REMOVE TO FRESH AIR & RINSE W/CLEAN WATER. OBTAIN MEDICAL ATTENTION
IN ALL CA SES.
======================Handling and Storage ======================
Handling and Storage Precautions:BE ALERT TO SHARP EDGES & UNSECURE
LIFTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN INHALATION CONTROLS ARE NOT SUFFICIENT TO
REDUCE EXPOSURE BELOW THE APPLICABLE EXPOSURE LIMIT THEN USE
NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:LOCAL EXHAUST/VENTILATION TO MAINTAIN EXPOSURE LEVELS BELOW
PRESCRIBED LIMITS NAY BE REQUIRED.
Supplemental Safety and Health
HEALTH HAZ CONT'D: COPPER: MAY CAUSE DERMATITIS. IRON: INHALATION OF
IRON OXIDE DUST CAUSES SIDEROSIS. TITANIUM: FIBROSIS OF THE LUNGS.
TUNGSTEN: IRRITATION OF EYES, SKIN & RESPIRATORY SYSTEM. MANGANE
SE: NEUROLOGICAL DYSFUNCTION. NICKEL: IRRITATIONOF RESPIRATORY
TRACT, BRONCHIAL IRRITATION, PULMONARY EDEMA.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:>2300F
Spec Gravity:7.6-7.8
Appearance and Odor:SOLID SILVER-GRAYISH BLACK W/NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Hazardous Decomposition Products:METALLIC DUST/FUMES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ACU-CAULK
CAGE:ACTAD
CAGE:ACTAD
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2 (2-METHOXYETHOXY)
CAS:141-43-5
RTECS #:KJ5775000
Fraction by Wt: >5.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:50 PPM
ACGIH TLV:50 PPM
Ingred Name:ETHYLENE GLYCOL (SARA 313) (CERCLA)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 5.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:50 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITATION. SKIN: IRRITATION.
INGEST: IRRITATION TO DIGESTIVE TRACT.
======================= First Aid Measures =======================
First Aid:EYE: IMMED FLUSH W/CLEAN WATER FOR 15 MIN. GET MED AID. SKIN:
RINSE W/CLEAN WATER. APPLY SKIN CREAM. INHAL: REMOVE TO FRESH AIR.
INGEST: IMMED DRINK LARGE QUANTITIES OF WATER. DONT INDUCE
VOMITING. GE T MED AID IMMED.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:NA
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:DILUTE W/PLENTY OF WATER AND FLUSH TO SANITARY
SEWER.
======================Handling and Storage ======================
Handling and Storage Precautions:DONT ALLOW PRODUCT TO FREEZE. KEEP
CONTAINER CLOSED WHEN NOT IN USE. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:EMPTY CONTAINERS RETAIN RESIDUE. DONT REUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Ventilation:MECHANICAL RECOMMENDED FOR ENCLOSED AREAS.
Other Protective Equipment:NOT REQUIRED
Work Hygienic Practices:USE GOOD HOUSE KEEPING PRACTICES.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NA
Vapor Pres:15
Vapor Density:1.1
VOC Pounds/Gallon:96
Evaporation Rate & Reference:<1.0 (BUAC)
Solubility in Water:DISPERSIBLE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
DO NOT MIX W/OTHER CHEMICALS
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:APPROVED LANDFILL COMPLYING W/ALL LOCAL, STATE
AND FEDERAL REGULATIONS OR AUTHORIZED WASTE DISPOSAL FACILITY.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:2600 PAPER
CAGE:19740
CAGE:19740
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM SILICATE (AS NUISANCE DUST OR PARTICULATES NOT
OTHERWISE REGULATED)
CAS:1302-76-7
RTECS #:BD1450000
Fraction by Wt: 100%
OSHA PEL:15 MG/M3 TOTAL DUST
ACGIH TLV:10 MG/M3 TDUST;8990
===================== Hazards Identification =====================
Effects of Overexposure:INHALATION, INGESTION AND SKIN IRRITATION.
======================= First Aid Measures =======================
First Aid:TERMINATE EXPOSURE.
======================Handling and Storage ======================
Handling and Storage Precautions:REMOVAL OF THIS PRODUCT AFTER USE MAY
RESULT IN THE GENERATION OF DUST.
Other Precautions:REPEATED INHALATION OF RESPIRABLE FREE CRYSTALLINE
SILICA DUST MAY CAUSE DELAYED LUNG INJURY (SILICOSIS).
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FULL FACEPIECE RESPIRATOR W/APPROPRIATE FILER &
PAD OR CARTRIDGE(S).
Ventilation:LOCAL EXHAUST AND MECHANICAL
Other Protective Equipment:LONG SLEEVE, LOOSE FITTING CLOTHING AND
BARRIER CREAM.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:2.56
Solubility in Water:INSOLUBLE
Appearance and Odor:FIBER SHAPE. NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:ROUTINE HOUSEKEEPING
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:V-724;POLY DIMETHYL SILOXANE
Preparer's Name:JASON E. BARNES
CAGE:64101
CAGE:64101
============= Composition/Information on Ingredients =============
Ingred Name:DIMETHYLPOLYSILOXANE
Other REC Limits:NONE SPECIFIED
Ingred Name:OTHER COMPONENTS (TYPE NOT SPECIFIED)
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE NOTED
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Effects of Overexposure:EYE:TEMPORARY EYE IRRITATION - AVOID HANDLING
MATERIAL AND RUBBING EYES.
Medical Cond Aggravated by Exposure:NONE STATED
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYE: FLUSH WITH WATER FOR 15
MINUTES WHILE HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION. SKIN:
WASH WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. IF
IRRITATION PER SISTS, GET MEDICAL ATTENTION. INGESTION: DO NOT
INDUCE VOMITING. IN GENERAL, NO TREATMENT IS REQUIRED. GET MEDICAL
ADVICE.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>500F,>260C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:SCRAPE UP BULK - REMOVE FILM WITH ABSORBENT
MATERIAL AND/OR HYDROPHOBIC SOLVENT. IF SOLVENT USED, OBSERVE ALL
HANDLING PROCEDURES FOR SOLVENT.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE- BE NEAT. CAN CAUSE SLIPPERY
CONDITIONS. OTHERWISE NORMAL STORAGE.
Other Precautions:NONE KNOWN
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Ventilation:NONE REQUIRED
Other Protective Equipment:EYE WASH
Work Hygienic Practices:USE GOOD CHEMICAL HYGIENE PRACTICE. AVOID
UNNECESSARY CONTACT.
Supplemental Safety and Health
NONE NORMALLY REQUIRED.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.03
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TRANSLUCENT-LIGHT WHITE PASTE- LITTLE OR NO ODOR
Percent Volatiles by Volume:<2
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS AND BASES
Stability Condition to Avoid:TEMPERATURE OVER 550F
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, SIO2,
DUST
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W ALL FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:L-TEC 65 (SEE SUPP DATA)
CAGE:DO412
CAGE:DO412
CAGE:55019
============= Composition/Information on Ingredients =============
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: <0.50%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: <2.50%
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: <1.50%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:COPPER (SARA III)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: <0.50%
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2MG/M3 FUME; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
Fraction by Wt: 0.75%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9293
Ingred Name:ALUMINUM
CAS:7429-90-5
RTECS #:BO0330000
Fraction by Wt: <0.50%
OSHA PEL:5 MG/M3 WELD FUME
ACGIH TLV:5 MG/M3 WELD FUME
Ingred Name:TANTALUM
CAS:7440-25-7
RTECS #:WW5505000
Fraction by Wt: <0.50%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3; DUST; 9192
Ingred Name:ZIRCONIUM
CAS:7440-67-7
RTECS #:ZH7070000
Fraction by Wt: <0.50%
OSHA PEL:5 MG/M3/10 STEL
ACGIH TLV:5 MG/M3/10 STEL;9192
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: TO 100%
OSHA PEL:10 MG FE/M3 TOTAL
ACGIH TLV:5 MG FE*2O*3/M3
Ingred Name:MFR STATES THAT ALL PRODUCTS COVERED BY MSDS MAY NOT
CONTAIN ALL OF THE LISTED INGREDIENTS.TYPICAL ANALYSIS IS AVAILABLE
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT IS NOT HAZARDOUS UNTIL IN USE.
WELDING CREATS METAL OXIDE FUMES CREATING METAL OXIDE FEVER AND
WITH CHRONIC BREATHING MAY CAUSE PERMANENT PULMONARY DISFUNCTION.
OTHER HAZARDS ARE ARC-RAYS (ULT RA VIOLET LIGHT),ELECTRIC
SHOCK,NOISE,THERMAL BURNS.
Effects of Overexposure:METAL FUMES:METALLIC TASTE,DIZZINESS,NAUSEA.
ARC RAYS:SUNBURN OF UNPROTECTED SKIN, PERMANENT VISION LOSS.
Medical Cond Aggravated by Exposure:PULMONARY DISFUNCTION.
======================= First Aid Measures =======================
First Aid:METAL FUME FEVER:REMOVE FROM EXPOSURE. GIVE OXYGEN IF
NEEDED,GET MEDICAL ATTENTION. ARC RAY BURNS:TREAT AS SUNBURN. GET
MEDICAL CARE FOR EYES. ELECTIC SHOCK:TURN OFF POWER. GIVE CPR OR
ARTIFICIAL RESP IRATION AS NEEDED. GET IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NON-FLAMMABLE. USE MEDIA APPROPRIATE FOR
SURROUNDING FIRE.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:WELDING ARCS,SPARKS,ETC. MAY IGNITE
COMBUSTABLES.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP OR PICK UP BEING CAREFULE NOT TO
CAUSE UNNECESSARY DUST.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL STORAGE CONDITIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR WHEN WELDING
IN ENCLOSED AREA AND/OR EXPOSED ABOVE PEL/TLV.
Ventilation:USE COMBINATION OF GENERAL VENTILATION AND LOCAL EXHAUST TO
KEEP EXPOSURE BELOW TLV/PEL.
Other Protective Equipment:CLOTHING TO PROTECT AGAINST ULTRA VIOLET &
THERMAL BURNS.
Work Hygienic Practices:USE GOOD INDUSTRIAL HYGIENE PRACTICE. USE GOOD
LIFTING TECHNIQUES.
Supplemental Safety and Health
MSDS ALSO COVERS L-TEC 29S,82,83,HI-84,85,85A,86,87HP,296,EASY GRIND.
================== Physical/Chemical Properties ==================
Solubility in Water:NIL
Appearance and Odor:COPPER COATED OR BARE STEEL WIRE.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:METAL FUMES,METAL OXIDES,CARBON AND
NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W FEDERAL,STATE,LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MULTILITH ELECTROSTATIC SOLUTION II, 83-5-1
CAGE:09177
CAGE:09177
============= Composition/Information on Ingredients =============
Ingred Name:FERRATE (4-), HEXACYANO-, TETRAPOTASSIUM; (POTASSIUM
HEXACYANOFERRATE)
CAS:13943-58-3
RTECS #:LJ8219000
Fraction by Wt: 2-4%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:GLYCEROL; (GLYCERINE)
CAS:56-81-5
RTECS #:MA8050000
Fraction by Wt: 20-25%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 (MIST) 9293
Ingred Name:AMMONIUM PHOSPHATE MONOBASIC; (MONOAMMONIUM PHOSPHATE)
CAS:7722-76-1
Fraction by Wt: 8-10%
Ingred Name:ARABIC GUM (ACACIA)
CAS:9000-01-5
RTECS #:CE5945000
Fraction by Wt: 1-2%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 60-70%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:MAY CAUSE IRRITATION.
SKIN:PROLONGED CONTACT MAY CAUSE IRRITATION. INHAL:NOT A NORMAL
ROUTE OF ENTRY. INGEST:LARGE DOSES MAY CAUSE GASTROINTESTINAL
IRRITATION. HEXACYANOFERRATE SALTS ARE CONSIDERE D TO BE OF SIGHT
TOXICITY TO HUMANS REGARDLESS OF WHETHER EXPOSURE IS ACUTE DERMAL,
ACUTE INGESTION OR (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:CHRONIC SYSTEMIC. ANY EFFECT ON THE
HUMAN BODY IS SLIGHT, TEMPORARY AND REVERSIBLE AND THE EFFECT
DISAPPEARS FOLLOWING TERMINATION OF EXPOSURE.
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WATER FOR AT LEAST 15 MINUTES. IF IRRITATION
PERSISTS, GET MD. SKIN:WASH W/SOAP & WATER. INHAL:NOT A NORMAL
ROUTE OF ENTRY. REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE O*2/ARTF
RESP), CALL MD . INGEST:INDUCE VOMITING. GET MDIMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:COMPATIBLE W/ALL FIRE FIGHTING MEDIA.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CATASTROPHIC ACCIDENTS, INVOLVING LG QTYS
OF PROD & ACCOMPANIED BY FIRE/CNTCT W/LG QTYS OF STRONG ACID,
RESPONSE PERS WILL BE REQ TO WEAR NIOSH/MSHA (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH W/WATER TO DRAIN.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DARK PLACE, AWAY FROM
STRONG ACIDS AND FIRE HAZARDS.
Other Precautions:READ LABEL PRECAUTIONS. DO NOT REUSE CONTAINER. KEEP
FROM REACH OF CHILDREN. FOR COMMERCIAL/INDUSTRIAL USE ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT APPLICABLE. WEAR NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NORMAL AIR CONDITIONING.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
EXPLO HAZ:APPROVED SCBA DUE TO AND DEPENDENT UPON QUANTITIES OF
CYANIDE.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:15 @ 25C
Spec Gravity:1.19
pH:4
Evaporation Rate & Reference:SLOWER THAN WATER
Solubility in Water:COMPLETE
Appearance and Odor:YELLOW GREEN LIQUID, SLIGHT ALMOND ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CHLORINE BLEACH, STRONG ACIDS.
Stability Condition to Avoid:STRONG LIGHT AND HEAT.
Hazardous Decomposition Products:PRODUCT WILL SLOWLY DECOMPOSE
W/FORMATION OF HYDROCYANIC ACID, COMPLEX CYANOFERRATES AND
CYANIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:SML QTYS SUCH AS EMPLOYED IN NORM USE MAY BE
FLUSHED W/WATER TO DRAIN. DO NOT MIX W/ACID WASTES. LG QTYS SHOULD
NOT BE DUMPED INTO WATERWAYS, CHECK FED, STATE & LOCAL REGS
REGARDING DISPOSAL OF HEXACY ANOFERRATE SALTS (GEN 2PPM MAX IN
STEAMS & LAKES).
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DISINFECTANT,GENERAL PURPOSE
Preparer's Name:DGSC-SSH
CAGE:13873
CAGE:13873
CAGE:3D869
============= Composition/Information on Ingredients =============
Ingred Name:NONYLPHENY ETHER OF POLYETHYLENE GLYCOL-IODINE COMPLEX
Fraction by Wt: 3.75%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYETHOXY POLYPROPOXY ETHANOL-IODINE COMPLEX
Fraction by Wt: 7.75%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NON HAZARDOUS INGREDIENTS
Fraction by Wt: 88.5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT IS IRRITATING TO EYES AND
MUCOUS MEMBRANES.
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of Overexposure:PROLONGED ABSORPTION MAY PRODUCE "IODISM" WHICH
IS CHARACTERIZED BY SKIN RASH, RUNNING NOSE, HEADACHE AND
IRRITATION OF MUCOUS MEMBRANES.INGESTION OF LARGE QUANTITIES OF
IODINE CAUSES ABDOMINAL PAIN, NAUSEA, VOMITING, AND DIARRHEA.
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH PLENTY OF WATER AND GET MEDICAL ATTENTION.
SKIN:FLUSH WITH WATER.IF IRRITATION PERSISTS, GET MEDICAL
ATTENTION. INGESTION:DRINK LARGE QUANTITY OF WATER, EGG WHITES, OR
GELATIN SOLUTION .GET MEDICAL ATTENTION.INHAL:REMOVE FROM
EXPOSURE.GET MEDICAL ATTENTION IF NEEDED.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER, CARBON DIOXIDE, DRY POWDER
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:MAY EMIT TOXIC FUMES OF IODINE IN A FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTACT YOUR LOCAL ENVIRONMMENTAL OFFICER.
IN APPROPIATE DISPOSAL CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID EXTREME TEMPERATURES. AVOID
CONATACT WITH FOOD.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NEEDED IN NORMAL SERVICE.
Ventilation:NO SPECIAL REQUIREMENT.
Other Protective Equipment:NONE.
Work Hygienic Practices:WASH HANDS.SEPERATE WORK CLOTHES FROM STREET
CLOTHES.LAUNDER WORK CLOTHES BEFORE REUSE.KEEP FOOD OUT OF THE WORK
AREA.
Supplemental Safety and Health
TSR REQUESTOR SPECIFIED SOS AS SHAPE PRODUCTS(3D869).DWIGHT GUSTAFSON
OF SHAPE SENT A LETTER ON 10OCT93 STATING THAT THIS ITEM WAS NOT
OFFERED IN THE LAST 10 YEARS;THEREFORE,OUR REQUEST FOR AN MSDS WA S
BEING DECLINED.THE INGREDIENTS WERE TAKEN FROM THE TIR.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F(100C)
Vapor Pres:26
Vapor Density:1
Spec Gravity:1.03
pH:3.2
Evaporation Rate & Reference:1 (WATER = 1)
Solubility in Water:COMPLETE
Appearance and Odor:DARK LIQUID, MILD IODINE ODOR.
Percent Volatiles by Volume:83
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALIES, REDUCING AGENTS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:IODINE VAPORS AT HIGH TEMPERATURES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:0872B1 PRO-SEAL 872 B-1/2 ACCELERATOR
Kit Part:Y
CAGE:83574
CAGE:83574
============= Composition/Information on Ingredients =============
Ingred Name:HYDROGENATED TERPHENYLS
CAS:61788-32-7
RTECS #:WZ6535000
Fraction by Wt: 30%
Other REC Limits:4.7 MG/CUM
OSHA PEL:0.5 PPM
ACGIH TLV:0.5 PPM
Ingred Name:1,3-DIPHENYL GUANADINE
CAS:102-06-7
RTECS #:MF0875000
Fraction by Wt: <5%
Ingred Name:MANGANESE DIOXIDE
CAS:1313-13-9
RTECS #:OP0350000
Fraction by Wt: 50%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM (MN)
Ingred Name:MAGNESIUM DICHROMATE*95-4*
CAS:13423-61-5
Fraction by Wt: 10%
OSHA PEL:0.5 MG/CUM
ACGIH TLV:0.5 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MANGANESE DIOXIDE-EYES/SKIN:
IRRITATOIN. INHALATION: DUST MAY PRODUCE MANGANESE PNEUMONITIS.
OVEREXPOSURE TO MANGANESE DIOXIDE MAY PRODUCE MANGANESE POISIONING.
INGESTION: CAN BE ABSORVED THROUGH DIGE STIVE SYSTEM.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:MANGANESE DIOXIDE-IRRITATION, APATHY, INSOMNIA,
WEAKNESS IN LEGS, MUSCULAR TWITCHING, EMOTIONAL DISTRESS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LUKE WARM WATER FOR 15 MINS. SKIN: WASH W/SOAP
& WATER. INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION
IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:>200F
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER
Fire Fighting Procedures:USE AIR SUPPLIED RESPIRATOR. USE WATER TO COOL
HEAT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:EXCESSIVE HEAT MAY CAUSE DECOMPOSITION OF
MANGANESE DIOXIDE, RESULTING IN OXIDATION & POSSIBLE IGNITION OF
HYDROCARBON VEHICLE.
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP INTO CONTAINERS. CLEAN UP RESIDUE W/A
SUITABLE SOLVENT.
======================Handling and Storage ======================
Other Precautions:AVOID INGESTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED
Ventilation:GENERAL
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE
SMOKING/EATING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NONE
Spec Gravity:1.93
Evaporation Rate & Reference:NON VOLATILE
Appearance and Odor:BLACK PASTE
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZABLE MATERIALS.
Hazardous Decomposition Products:OXIDES OF CARBON & NITROGEN. MANGANESE
& CHROMIUM COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. EPA NO. D-007 HAZARDOUS WASTE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:442 SOLUTION, 1500 PPM, TDS/CONDUCTIVITY (SUPP DATA)
Preparer's Name:JERRY ADAMS
CAGE:30053
CAGE:30053
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM BICARBONATE (1:1); (SODIUM BICARBONATE)
CAS:144-55-8
RTECS #:VZ0950000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM SULFATE; (SODIUM SULFATE)
CAS:7757-82-6
RTECS #:WE1650000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM CHLORIDE
CAS:7647-14-5
RTECS #:VZ4725000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATING TO EYES & MUCOUS MEMBRANES
& DIGESTIVE TRACT.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . EYES:FLUSH W/WATER FOR AT LEAST 15 MINUTES. SKIN:WASH
W/SOAP & WATER. INGEST:DRINK PLENTY OF WATER, DO NOT INDUCE
VOMITING.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
NON-FLAMMABLE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN SPILL USING ABSORBENT MATERIALS USING
SOAP & WATER & THEN VENTILATE AREA.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE, NORMAL USE
DOES NOT GENERATE A HAZARDOUS SITUATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NOT APPLICABLE.
Ventilation:LOCAL VENTILATION.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . STANDARD LAB CLOTHES.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:STANDARD SOLUTION.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>216F,>102C
Melt/Freeze Pt:M.P/F.P Text:>-4F,>-20C
Spec Gravity:>1 (H*2O=1)
Solubility in Water:MISCIBLE
Appearance and Odor:COLORLESS LIQUID; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:MATL DOES NOT HAVE EPA WASTE NUMBER & IS NOT A
LISTED WASTE, HOWEVER CONSULTATION W/PERMITTED WASTE DISP SITE
(TSD) SHOULD BE ACCOMPLISHED. NOTE:ALWAYS CONT PERMITTED WASTE
DISPOSER SITE (TSD) TO ASSU RE COMPLIANCE & ACCORD W/FED, STATE &
LOC REGS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ARGON, REFRIGERATED LIQUID
Resp. Party Other MSDS Num.:1013, PUB # 320-9447
CAGE:00742
CAGE:00742
============= Composition/Information on Ingredients =============
Ingred Name:ARGON
CAS:7440-37-1
RTECS #:CF2300000
> Wt:99.
OSHA PEL:NONE ESTABLISHED
OSHA STEL:NONE ESTABLISHED
ACGIH TLV:SIMPLE ASPHYXIANT
ACGIH STEL:SIMPLE ASPHYXIANT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:POTENTIAL HEALTH EFFECTS INFORMATION:
INHALATION: SIMPLE ASPHYXIANT. EYE CONTACT: TISSUE FREEZING AND
SEVERE CRYOGENIC BURNS IF CONTACTED INTO EYES. SKIN CONTACT: TISSUE
FREEZING AND SEVERE CRYOGENIC BURNS OF SKIN. OTHER EFFECTS OF
OVEREXPOSURE: NONE. CHRONIC EFFECTS: NONE ESTABLISHED.
EMERGENCY OVERVIEW: LIQUID ARGON IS A COLORLESS, ODORLESS,
EXTREMELY COLD LIQUID AND GAS UNDER PRESSURE. IT C AN CAUSE RAPID
SUFFOCATION WHEN CONCENTRATIONS ARE SUFFICIENT TO REDUCE OXYGEN
LEVELS BELOW 19.5%. SELF-CONTAINED BREATHING APPARATUS (SCBA) MAY
BE REQUIRED. CONTACT WITH LIQUID OR COLD VAPORS CAN CAU SE (SIGNS
AND SYMPTOMS OF OVEREXPOSURE)
Explanation of Carcinogenicity:ARGON IS NOT LISTED BY NTP, OSHA OR
IARC.
Effects of Overexposure:HEALTH HAZARDS ACUTE AND CHRONIC (CONT): SEVERE
FROSTBITE. COLD VAPORS IN THE AIR WILL APPEAR AS A WHITE FOG DUE TO
CONDENSATION OF MOISTURE. WHILE THIS MAY INDICATE THE PRESENCE OF
THE GAS IT SHOULD NOT BE USED TO DETERMINE ITS CONCENTRATION IN
THE ATMOSPHERE. OXYGEN CONCENTRATIONS MUST BE MONITORED IN THE
RELEASE AREA. ALL CRYOGENIC LIQUIDS PRODUCE LARGE VOLUMES OF GAS
WHEN THEY VAPORIZE. ONE VO LUME OF LIQUID ARGON WILL EXPAND TO
PRODUCE 841 EQUIVALENT VOLUMES OF GAS.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:INHALATION: PERSONS SUFFERING FROM LACK OF OXYGEN SHOULD BE
REMOVED TO FRESH AIR. IF VICTIM IS NOT BREATHING, ADMINISTER
ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, ADMINISTER
OXYGEN. OBTAIN PR OMPT MEDICAL ATTENTION. EYE CONTACT: FOR EXPOSURE
TO LIQUID, IMMEDIATELY WARM FROSTBITE AREA WITH WARM WATER (NOT TO
EXCEED 105 F). CALL A PHYSICIAN. SKIN CONTACT: REMOVE ANY CLOTHING
THAT MAY RESTRIC T CIRCULATION TO FROZEN AREA. DO NOT RUB FROZEN
PARTS AS TISSUE DAMAGE MAY RESULT. AS SOON AS PRACTICAL, PLACE THE
AFFECTED AREA IN A WARM BATH - WHICH HAS A TEMPERATURE NOT TO
EXCEED 105 F (40 C). NE VER USE DRY HEAT. (TOXICOLOGICAL INFO)
===================== Fire Fighting Measures =====================
Autoignition Temp:Autoignition Temp Text:N/FLAM
Lower Limits:NOT APPLIC
Upper Limits:NOT APPLIC
Extinguishing Media:ARGON IS NONFLAMMABLE AND DOES NOT SUPPORT
COMBUSTION. USE EXTINGUISHING MEDIA APPROPRIATE FOR THE SURROUNDING
FIRE. HAZARDOUS COMBUSTION PRODUCTS: NONE KNOWN.
Fire Fighting Procedures:ARGON IS A SIMPLE ASPHYXIANT. IF POSSIBLE,
REMOVE ARGON CONTAINERS FROM FIRE AREA OR COOL WITH WATER. DO NOT
DIRECT WATER SPRAY AT THE CONTAINER VENT. SELF-CONTAINED BREATHING
APPARATUS (NIOSH APPROVE D - ) MAY BE REQUIRED FOR RECUE WORKERS.
EVACUATE THIS AREA.
Unusual Fire/Explosion Hazard:LIQUID ARGON WHEN SPILLED WILL VAPORIZE
RAPIDLY FORMING AN OXYGEN-DEFICIENT VAPOR CLOUD. EVACUATE VAPOR
CLOUD AREA. VISIBILITY MAY BE OBSCURED IN VAPOR CLOUD. CONTAINER
PRESSURE CAN BUILD UP DUE TO HE AT & MAY RUPTURE IF PRESSURE RELEIF
DEVICES FAIL TO FUNCTION. CONTACT WITH LIQUID OR GASEOUS ARGON MAY
CAUSE FROSTBITE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL PERSONNEL FROM THE AFFECTED AREA.
SHUT OFF SOURCE OF ARGON, IF POSSIBLE WITHOUT RISK. VENTILATE ARE
OR REMOVE CONTAINERS TO A WELL VENTILATED LOCATION. TO INCREASE
RATE OF VAPORIZATION SP RAY LARGE AMOUNTS OF WATER ONTO THE SPILL
FROM AN UPWIND LOCATION. DO NOT SPRAY WATER DIRECTLY AT LEAK. IF
LEAKING FROM CONTAINER OR ITS VALVE, CONTACT YOUR SUPPLIER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE: STORE AND USE WITH ADEQUATE
VENTILATION. DO NOT STORE IN A CONFINED SPACE. CRYOGENIC CONTAINERS
ARE EQUIPPED WITH PRESSURE RELIEF DEVICES TO CONTROL INTERNAL
PRESSURE. UNDER NORMAL CONDITIONS THESE CONTAINERS WILL
PERIODICALLY VENT PRODUCT. DO NOT REMOVE PLUG OR TAMPER (ECOLOGICAL
INFO)
Other Precautions:SPECIAL PRECAUTIONS: SOME METALS, SUCH AS CARBON
STEEL, MAY BECOME BRITTLE AND FRACTURE AT LOW TEMPERATURES. FOR
ADDITIONAL INFORMATION CONCERNING STORAGE AND HANDLING REFER TO
COMPRESSED GAS ASSOCIA TION PAMPHLET P-12 SAFE HANDLING OF
CRYOGENIC LIQUIDS, AVAILABLE FROM THE COMPRESSED GAS ASSOCIATION
INC (703) 412-0900.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:GENERAL USE: NONE REQUIRED. EMERGENCY USE:
(NIOSH APPROVED - ) SELF-CONTAINE BREATHING APPARATUS (SCBA) OR
POSITIVE PRESSURE AIRLINE WITH MASK ARE TO BE USED IN
OXYGEN-DEFICIENT ATMOSPHERE. RESPI RATORS WILL NOT FUNCTION.
Ventilation:NATURAL OR MECHANICAL TO PREVENT OXYGEN DEFICIENT
ATMOSPHERES UNDER 19.5 % OXYGEN.
ARE RECOMMENDED.
Other Protective Equipment:SAFETY SHOES ARE RECOMMENDED WHEN HANDLING
LIQUID CONTAINERS. LONG SLEEVE SHIRTS AND TROUSERS WITHOUT CUFFS.
Supplemental Safety and Health
CHEMICAL NAME: ARGON. FORMULA: AR. SYNONYMS: CRYOGENIC LIQUID ARGON,
LIQUID ARGON, LAR. LIQUID ARGON IS SOLD AS PURE PRODUCT > 99%.
PHYS/CHEM PROPS (CONT): MOLECULAR WEIGHT: 39.95. GAS DENSIT Y(AT
70 F (21.1 C) AND 1 ATM): 0.103 LB/FT3 (1.650 KG/M3). EXPANSION
RATIO ()FOR LIQUID TO GAS) 70 F (21.1 C): 1 TO 841.
================== Physical/Chemical Properties ==================
HCC:G3
Boiling Pt:=-185.5C, -302.2F
B.P. Text:-302.2F/-185.9C @ 1 AT
Melt/Freeze Pt:=-189.2C, -308.9F
M.P/F.P Text:-308.9F/-189.4C
Vapor Density:.103 LB/F3
Spec Gravity:1.38 (AIR = 1)
Solubility in Water:0.056 (VOL/VOL @ 32F/0C)
Appearance and Odor:COLORLESS, ODORLESS CRYOGENIC LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
Conditions to Avoid Polymerization:WILL NOT OCCUR
=================== Toxicological Information===================
Toxicological Information:ARGON IS A SIMPLE ASPHYXIANT. SIGNS
AND SYMPTOMS OF OVEREXPOSURE (CONT): IN CASE OF MASSIVE EXPOSURE,
REMOVE CLOTHING WHILE SHOWERING WITH WARM WATER. CALL A PHYSICIAN
AS SOON AS POSSIBLE. FRO ZEN TISSUE IS PAINLESS AND APPEARS WAXY
WITH A POSSIBLE YELLOW COLOR. IT WILL BECOME SWOLLEN, PAINFUL, AND
PRONE TO INFECTION WHEN THAWED. IF THE FROZEN PART OF THE BODY HAS
BEEN THAWED, COVER THE ARE A WITH DRY STERILE DRESSING WITH A LARGE
BULKY PROTECTIVE COVERING, PENDING MEDICAL ATTENTION.
===================== Ecological Information =====================
Ecological:NO ADVERSE ECOLOGICAL EFFECTS ARE EXPECTED. ARGON DOES NOT
CONTAIN ANY CLASS I OR CLASS II OZONE DEPLETING CHEMICALS (40 CFR
PART 82). ARGON IS NOT LISTED AS A MARINE POLLUTANT BY DOT (49 CFR
PART 171 ). HANDLING & STORAGE PRECAUTIONS(CONT): WITH
PRESSURE RELIEF DEVICE. HANDLING: NEVER ALLOW ANY UNPROTECTED PART
OF THE BODY TO TOUCH UNINSULATED PIPES OR VESSELS WHICH CONTAIN
CRYOGENIC FLUID S. THE EXTREMELY COLD METAL WILL CAUSE THE FLESH TO
STICK FAST & TEAR WHEN ONE ATTEMPTS TO WITHDRAW FROM IT. USE A
SUITABLE HAND TRUCH FOR CONTAINER MOVEMENT. CONTAINERS SHALL BE
HANDLED AND STORED I N AN UPRIGHT POSITION. (STATE REGS)
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT ATTEMPT TO DISPOSE OF RESIDUAL OR UNUSED
QUANTITIES. CONTACT YOUR SUPPLIER. FOR EMERGENCY DISPOSAL,
DISCHARGE SLOWLY INTO THE ATMOSPHERE IN A WELL VENTILATED AREA OR
OUTDOORS.
=================== MSDS Transport Information ===================
Transport Information:DOT / IMO SHIPPING NAME: ARGON, REFRIGERATED
LIQUID. HAZARD CLASS: 2.2 (NONFLAMMABLE GAS). IDENTIFICATION
NUMBER: UN1951. PRODUCT RQ: NOT APPLICABLE. SHIPPING LABEL(S):
NONFLAMMABLE GAS. PLACARD(WHEN REQUIRED): NONFLAMMABLE GAS.
SPECIAL SHIPPING INFORMATION: TRANSPORT SECURED UPRIGHT POSITION IN
A WELL VENTILATED TRUCK. NEVER TRANSPORT IN PASSENGER COMPARTMENT
OR ENCLOSED VEHICLE. SHIPMENT OF COMPRESSED GAS CONTAINERS WHICH
HAVE NOT BEEN FILLED WITH THE OWNERS CONSENT IS A VIOLATION OF
FEDERAL LAW (49 CFR PART 173.301(B)).
===================== Regulatory Information =====================
SARA Title III Information:SUPERFUND AMENDMENT AND REAUTHORIZATION ACT:
SECTION 302/304: REQUIRES EMERGENCY PLANNING ON THRESHOLD PLANNING
QUANTITIES (TPQ) AND RELEASE REPORTING BASED ON REPORTABLE
QUANTITIES (RQ) OF EPA'S EXTR EMELY HAZARDOUS SUBSTANCES (40 CFR
PART 370). EXTREMELY HAZARDOUS SUBSTANCES: NONE. THRESHOLD PLANNING
QUANTITY (TPQ): NONE. SECTION 311/312: REQUIRE SUBMISSION OF
MATERIAL SAFETY DATA SHEETS (MSDS)AND CHEMICAL INVENTORY
REPORTING WITH IDENTIFICATION OF EPA DEFINED HAZARD CLASSES (40 CFR
PART 370). THE HAZARD CLASSES FOR THIS PRODUCT ARE: IMMEDIATE
HEALTH: YES, DELAYED HEALTH: NO, PRESSURE: YES, REACTIVITY: NO,
FIRE: NO. (STATE REGS)
Federal Regulatory Information:EPA - ENVIRONMENTAL PROTECTION AGENCY:
CERCLA: COMPREHENSIVE ENVIRONMENTAL RESPONSE, COMPENSATION, AND
LIABILITY ACT OF 1980 (40 CFR PARTS 117 AND 302): REPORTABLE
QUANTITY (RQ): NONE. 40 CFR PART 68 : RISK MANAGEMENT PROGRAMS FOR
CHEMICAL ACCIDENTAL RELEASE PREVENTION: ARGON IS NOT LISTED AS A
REGULATED SUBSTANCE. TSCA: TOXIC SUBSTANCE CONTROL ACT: ARGON IS
NOT LISTED ON THE TSCA INVENTORY. OSH A - OCCUPATIONAL SAFETY AND
HEALTH ADMINISTRATION: 29 CFR PART 1910.119: PROCESS SAFETY
MANAGEMENT O F HIGHLY HAZARDOUS CHEMICALS: ARGON IS NOT LISTED IN
APPENDIX A AS A HIGHLY HAZARDOUS CHEMICAL.
State Regulatory Information:N/P. SARA III (CONT): SECTION 313:
REQUIRES SUBMISSION OF ANNUAL REPORTS OF RELEASE OF TOXIC CHEMICALS
THAT APPEAR IN 40 CFR PART 372: ARGON DOES NOT REQUIRE REPORTING
UNDER SECTION 313. ECOLOGICAL INFO (CONT): DO NOT DROP,
TIP, OR ROLL CONTAINERS ON THEIR SIDES. DO NOT REMOVE OR
INTERCHANGE CONNECTIONS. IF USER EXPERIENCES ANY DIFFICULTY
OPERATING CONTAINER VALVE OR WITH CONTAINER C ONNECTIONS
DISCONTINUE USE AND CONTACT SUPPLIER. USE THE PROPER CONNECTION. DO
NOT USE ADAPTERS. US E PIPING AND EQUIPMENT ADEQUATELY DESIGNED TO
WITHSTAND PRESSURES TO BE ENCOUNTERED. USE A CHECK VALVE OR OTHER
PROTECTIVE (OTHER INFO)
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:COM-4D LEAD/ACID STORAGE BATTERY-4 (MOTIVE
CAGE:20038
CAGE:0K4U5
CAGE:90660
CAGE:20038
============= Composition/Information on Ingredients =============
Ingred Name:LEAD (SARA III)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: >60%
Other REC Limits:NONE SPECIFIED.
OSHA PEL:0.05 MG/M3;1910.1025
ACGIH TLV:0.15 MG/M3;DUST 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ANTIMONY (SARA III)
CAS:7440-36-0
RTECS #:CC4025000
Fraction by Wt: >2%
Other REC Limits:NONE SPECIFIED.
OSHA PEL:0.5 MG/M3
ACGIH TLV:0.5 MG/M3; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ARSENIC (SARA III)
CAS:7440-38-2
RTECS #:CG0525000
Fraction by Wt: <0.2%
Other REC Limits:NONE SPECIFIED.
OSHA PEL:0.5 MG/M3 (AS)
ACGIH TLV:0.01,A1 MG/M3; 9394
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CALCIUM
CAS:7440-70-2
RTECS #:EV8040000
Fraction by Wt: <0.2%
Other REC Limits:NONE SPECIFIED.
OSHA PEL:NOT ESTABLISHED.
ACGIH TLV:NOT ESTABLISHED.
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
Fraction by Wt: <0.2%
Other REC Limits:NONE SPECIFIED.
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9192
Ingred Name:POLYCARBONATE
Fraction by Wt: <6%
Other REC Limits:NONE SPECIFIED.
OSHA PEL:NOT ESTABLISHED.
ACGIH TLV:NOT ESTABLISHED.
Ingred Name:SULFURIC ACID (SARA III)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 10-30%
Other REC Limits:NONE SPECIFIED.
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SILICA DIOXIDE
CAS:60676-86-0
RTECS #:VV7328000
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED.
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RAT LD50 IS NOT KNOWN
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:PRODUCT CONTAINS LEAD, ARSENIC AND
SULFURIC ACID. SULFURIC ACID AS A LIQUID OR MIST IS A CORROSIVE
CAUSING SEVERE BURNS TO EYES, SKIN, RESPIRATORY TRACT. INGESTION OF
LEAD MAY CAUSE STOMACH CRAMPS, AN EMIA, NERVE DAMAGE. CONTACT WITH
ACID ORMETALS IS HIGHLY UNLIKELY UNLESS THE BATTERY IS OVERCHARGED
OR CASE IS BROKEN.
Explanation of Carcinogenicity:ARSENIC AND LEAD ARE LISTED BY NTP AND
IARC AS A CARCINOGEN.ARSENIC IS ALSO LISTED BY OSHA AS A
CARCINOGEN.
Effects of Overexposure:CONTACT WITH SULFURIC ACID IS THE MOST LIKELY
EXPOSURE, PRODUCING SEVERE IRRITATION OR BURNS TO EYES, SKIN, NOSE,
AND THROAT. LEAD INGESTION MAY CAUSE STOMACH CRAMPS, LOSS OF
APPETITE, MUSCULAR ACHES AND WEAKNESS, SLEEP DISTURBANCES AND
IRRITABILITY, ANEMIA, AND NERVE DAMAGE.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING DISEASES
INVOLVING THE EYES, SKIN, RESPIRATORY TRACT, LIVER, KIDNEY, AND
NEUROLOGIC SYSTEM MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:FIRST AID IS GIVEN FOR SULFURIC ACID CONTACT. EYES: FLUSH
WITH LARGE AMOUNTS OF WATER. GET MEDICAL ATTENTION. SKIN: REMOVE
CONTAMINATED CLOTHING. WASH AREA WITH SOAP AND WATER. INHALATION:
MOVE TO FRE SH AIR. IF NOT BREATHING GIVE CPR. IF BREATHING
DIFFICULT GIVE OXYGEN. GET MEDICAL ATTENTION. INGESTION: DO NOT
INDUCE VOMITING. GIVE 2 LARGE GLASSES OF MILK OR WATER. GET MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Lower Limits:4.1 (H2)
Upper Limits:74.2 (H2)
Extinguishing Media:PRODUCT IS NON FLAMMABLE. USE MEDIA APPROPRIATE FOR
SOUROUNDING AREA, CARBON DIOXIDE, FOAM, HALOGEN, DRY CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA
AND FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. IF
BATTERY IS ON CHARGE, SHUT OFF POWER.
Unusual Fire/Explosion Hazard:WHEN BEING CHARGED THIS BATTERY GENERATES
HYDROGEN GAS WHICH MAY FORM EXPLOSIVE MIXTURES WITH AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:IF ACID IS SPILLED, NEUTRALIZE WITH SODIUM
CARBONATE (SODA ASH) OR SODIUM BICARBONATE (BAKING SODA). PLACE
WASTE IN AN ACID RESISTANT CONTAINER FOR RECYCLE OF THE LEAD.
Neutralizing Agent:SODIUM CARBONATE (SODA ASH) OR SODIUM BICARBONATE
(BAKING SODA).
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY AREA, AWAY FROM
IGNITION SOURCES DURING AND AFTER CHARGING. PROTECT FROM PHYSICAL
DAMAGE. PROTECT TERMINALS FROM SHORT CIRCUITS.
Other Precautions:DO NOT SHOTR TERMINAL WITH TOOLS, ETC.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR WILL NOT NORMALLY BE NECESSARY. USE
NIOSH/MSHA APPROVED RESPIRATOR FOR ACID DUST/MIST IF EXPOSURE IS
ABOVE THE TLV/PEL. SEE 29 CFR 1910.134 FOR REGULATIONS PERTAINING
TO RESPIRATOR USE.
Ventilation:NOT NORMALLY REQUIRED. USE LOCAL EXHAUST WITH 3-4 AIR
CHANGES/HR DURING CHARGING CYCLES TO AVOID EXPLOSIVE H2 BUILD UP.
Other Protective Equipment:NORMAL WORK CLOTHING. PROTECT WITH
IMPERVIOUS APRON AND/OR BOOTS IF ACID IS LEAKING.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:Z4
Appearance and Odor:12 VOLT LEAD-ACID BATTERY, POLYCARBONATE CASING.
PUNGENT ODOR (ACID).
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:HIGH HEAT, OPEN FLAME, AND PROLONGED
OVERCHARGE.
Hazardous Decomposition Products:MAY GENERATE HYDROGEN GAS AND SULFURIC
ACID, ARSINE, AND/OR STIBINE MIST ON OVERCHARGE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS. RETURN SPENT BATTERY TO SECONDARY LEAD
SMELTER.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FC-206CF, LIGHT WATER BRAND AQUEOUS FILM FORMING FOAM
CAGE:28112
CAGE:28112
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 78-81%
Other REC Limits:NONE SPECIFIED
Ingred Name:DIETHYLENE GLYCOL MONOBUTYL ETHER
CAS:112-34-5
RTECS #:KJ9100000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
Ingred Name:FLUOROALKYLAMIDE DERIVATIVE
Fraction by Wt: 1 - 2%
Other REC Limits:NONE SPECIFIED
Ingred Name:ALKYL SULFATE SALTS
Fraction by Wt: 1 - 5%
Other REC Limits:NONE SPECIFIED
Ingred Name:ETHANOL, 2,2',2"-NITRILOTRI-; (TRIETHANOLAMINE)
CAS:102-71-6
RTECS #:KL9275000
Fraction by Wt: 0.1-1.0%
Other REC Limits:NONE SPECIFIED
ACGIH TLV:5 MG/M3
Ingred Name:UREA
CAS:57-13-6
RTECS #:YR6250000
Fraction by Wt: 3 - 7%
Other REC Limits:NONE SPECIFIED
Ingred Name:PERFLUOROAKYL SULFONATE SALTS
Fraction by Wt: 0.1 - 1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MODERATE EYE IRRITATION. MILD SKIN
IRRITATION. SKIN MAY ABSORB HARMFUL AMOUNTS. SINGLE OVEREXPOSURE,
MAY CAUSE CENTRAL NERVOUS SYSTEM DEPRESSION & IRRITATION (UPPER
RESPIRATORY), BLOOD DISORDERS, BONE MARROW DEPRESSION, KIDNEY
EFFECTS, LIVER EFFECTS, PULMONARY EDEMA. INGESTION IS NOT A LIKELY
ROUTE EXPOSURE.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE:REDNESS, SWELLING, PAIN, TEARING & HAZY
VISION. SKIN:REDNESS, SWELLING, & ITCHING. INHALATION:HEADACHE,
DIZZINESS, DROWSINESS, INCOORDINATION, SLOWED REACTION TIME,
SLURRED SPEECH, GIDDINESS & UNC ONSCIOUSNESS. SORENESS OF THE NOSE
& THROAT, COUGHING AND SNEEZING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:IMMEDIATELY FLUSH WITH WATER FOR AT LEAST 15 MINUTES.
GET MEDICAL ATTENTION. SKIN:FLUSH SKIN WITH LARGE AMOUNTS OF WATER.
IF IRRITATION PERSISTS, GET IMMEDIATE MEDICAL ATTENTION.
INHALATION:REMOV E PERSON TO FRESH AIR. IF SYMPTOMS CONTINUE, CALL
A PHYSICIAN. INGESTION:DRINK TWO GLASSES OF WATER. CALL A PHYSICIAN
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:NONE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:PRODUCT IS A FIRE EXTINGUISHING AGENT.
Unusual Fire/Explosion Hazard:SEE HAZARDOUS DECOMPOSITION PRODUCTS
SECTION FOR PRODUCTS OF COMBUSTION.
================== Accidental Release Measures ==================
Spill Release Procedures:OBSERVE PRECAUTIONS FROM OTHER SECTIONS. COVER
WITH ABSORBENT MATERIAL. COLLECT SPILLED MATERIAL. CLEANUP RESIDUE
WITH WATER. PLACE IN APPROVED METAL CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL PLACE. STORE AWAY FROM
HEAT. STORE OUT OF DIRECT SUNLIGHT. KEEP CONTAINER DRY. KEEP
CONTAINER IN WELL- VENTILATED AREA.
Other Precautions:KEEP CONTAINER TIGHTLY CLOSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID BREATHING OF VAPORS, MISTS OR SPRAY.
SELECT ONE OF THE FOLLOWING NIOSH APPROVED RESPIRATORS BASED ON
AIRBORNE CONCENTRATION OF CONTAMINANTS & I/A/W OSHA REGULATIONS:
HALF MASK ORGANIC VAPOR RESP IRATOR WITH DUST/MIST PREFILTER.
Ventilation:USE WITH ADEQUATE DILUTION VENTILATION.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NONE
Boiling Pt:=100.C, 212.F
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:17.8
Vapor Density:0.62
Spec Gravity:1
VOC Pounds/Gallon:103
pH:8.50
Evaporation Rate & Reference:< 1 (BUTYL ACETATE = 1)
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR, AMBER COLORED LIQUID
Percent Volatiles by Volume:90
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN, OXIDES OF SULFUR, HYDROGEB CYANIDE, HYDROGEN
FLUORIDE, AMMONIA.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:SLOWLY DISCHARGE SPENT SOL & SMALL AMOUNTS (<5
GAL) TO A WASTE WATER TREATMENT SYSTEM. REDUCE DISCHARGE RATE IF
FOAMING OCCURS. INCINERATE BULK PRODUCT IN AN INDUSTRIAL OR
COMMERCIAL INCINERATOR. SEE WITH APPLICABLE REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ALPHA STYLE D-24 SEWING THREAD
CAGE:09079
CAGE:09079
CAGE:3S126
============= Composition/Information on Ingredients =============
Ingred Name:GLASS, FIBROUS (THIS IS THE ONLY INGREDIENT HAZARDOUS OR
OTHERWISE THAT WAS LISTED ON THE MSDS.)
RTECS #:LK3651000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 (DUST)
ACGIH TLV:10 MG/M3 (DUST);9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS MATERIAL WILL NOT ENTER THE BODY
DURING NORMAL USE. NO HEALTH HAZARDS KNOWN
Explanation of Carcinogenicity:THIS MATERIAL IS NOT KOWN TO BE A
CARCINOGEN.
Effects of Overexposure:NONE KNOWN
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:WASH THOROUGHLY WITH SOAP & WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:>482F,>250C
Extinguishing Media:WATER, CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:AVOID INHALATION OF GASES OR FUMES WHEN
EXPOSED TO TEMPERATURES EXCEEDING 450F
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:MATERIAL IS A SOLID.
Neutralizing Agent:NO INFORMATION GIVEN ON MSDS BY MFR.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE KNOWN
Other Precautions:NONE KNOWN
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:NONE
Other Protective Equipment:NONE
Work Hygienic Practices:WASH THOROUGHLY WITH SOAP & WATER AFTER
HANDLING.
Supplemental Safety and Health
KEY2:KT THE ITEM OF SUPPLY IS AN ARTICLE AND AS SUCH, NEITHER AN MSDS
OR A HAZARD LABEL ARE REQUIRED. THIS IS PART C USED IN THE
CONSTRUCTION OF THE ITEM OF SUPPLY.
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NONE
Melt/Freeze Pt:M.P/F.P Text:>1000F,>538
Spec Gravity:2.1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TAN THREAD NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NONE KNOWN
Hazardous Decomposition Products:HYDROGEN FLUORIDE CARBON MONOXIDE
CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:BURIAL IN A FEDERAL OR STATE APPROVED LANDFILL.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:5825 DECORATOR
CAGE:11348
CAGE:11348
============= Composition/Information on Ingredients =============
Ingred Name:SILICA DIOXIDE, CRYSTALLINE QUARTZ, SAND (SUSPECTED HUMAN
CARCINOGEN BY IARC, NTP)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 13.78%
Other REC Limits:0.05 MG/CUM NIOSH
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:WEIGHT PER GALLON IN POUNDS: 10.03
RTECS #:9999999WG
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:CONTAINS SILICA WHICH WHEN DRY &
REDUCED TO DUST IS HAZARDOUS & CAN CAUSE LUNG DAMAGE (SILICOSIS).
Explanation of Carcinogenicity:SEE INGREDIENTS
======================= First Aid Measures =======================
First Aid:INGESTION: GIVE 2 GLASSES OF WATER & INDUCE VOMITING BY
PUTTING FINGER DOWN THROAT. SKIN: FLUSH W/WATER. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WILL NOT BURN UNTIL WATER HAS EVAPORATED, FOR
RESIDUAL SOLIDS USE WATER SPRAY, CO2, DRY CHEMICAL, UNIVERSAL
FOAMS.
================== Accidental Release Measures ==================
Spill Release Procedures:COLLECT MAJOR SPILLS FOR DISPOSAL. MINOR
SPILLS, REMOVE THE EXCESS & USE SOAP & WATER. DON'T USE GASOLINE OR
FLAMMABLE SOLVENTS.
======================Handling and Storage ======================
Other Precautions:WHEN SUBJECTED TO OPERATIONS SUCH AS MILING, SAWING,
SANDING OR DRIED COATING, THE RESULTANT DUST CONSTITUTES A
HAZARDOUS DUST OF NON-VOLATILE MATERIALS IN INGREDIENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE DUST RESPIRATOR WHEN SANDING, MILLING OR
SAWING ANY ITEMS PAINTED W/THIS PRODUCT.
Ventilation:NORMAL
Other Protective Equipment:EYE WASH
Work Hygienic Practices:WASH HANDS THOROUGHLY W/SOAP & WATER AFTER USE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:8-533F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:72%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:BURY IN A LANDFILL IN ACCORDANCE W/LOCAL, STATE
& LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:321 DRY FILM LUBRICANT
CAGE:5D028
CAGE:5D028
CAGE:71984
CAGE:7B953
============= Composition/Information on Ingredients =============
Ingred Name:MOLYBDENUM DISULFIDE
CAS:1317-33-5
RTECS #:QA4697000
Fraction by Wt: 18%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG MO/M3
ACGIH TLV:5 MG MO/M3
Ingred Name:GRAPHITE, NATURAL
CAS:7782-42-5
RTECS #:MD9659600
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MPPCF; Z-3
ACGIH TLV:2 MG/M3 RDUST; 9596
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 65%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9596
Ingred Name:POLY(BUTYLTITANATE)
CAS:9022-96-2
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:S: 50 PPM CEILING
Ingred Name:ZINC SALT 5-NITOR-1,3-BENZENNE-DICARBOXYLIC ACID MFR GIVES
CAS AS 60580612
Fraction by Wt: 1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT GIVEN FOR PRODUCT AS A WHOLE
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DIRECT EYE CONTACT IRRITATES
MODERATELY WITH REDNESS AND SWELLING. REPEATED OR PROLONGED SKIN
CONTACT MAY CAUSE DEFATTING OF THE SKIN AND DERMATITIS. SHORT VAPOR
EXPOSURE MAY CAUSE DROWSINESS, IRRITAT E NOSE AND THROAT AND CAUSE
LUNG/LIVER INJURY. SMALL AMOUNTS TRANSFERRED TO MOUTH BY FINGERS
SHOULD NOT INJURE.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE REDNESS/SWELLING/IRRITATION, SKIN
IRRITATION, DERMATITIS, DROWSINESS, NOSE IRRITATION, THROAT
IRRITATION, LUNG INJURY, LIVER INJURY.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH WITH SOAP & WATER. IF IRRITATION PERSIST, GET MEDICAL
ATTENTION. INHAL ATION: REMOVE TO FRESH AIR. RESTORE BREATHING. GET
MEDICAL ATTENTION. INGESTION: GET IMMEDIATE MEDICAL ATTENTION. ONLY
INDUCE VOMITING AT INSTRUCTIONS OF A PHYSICIAN. NOTHING BY MOUTH IF
UNCONSCIOUS.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:108F,42C
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:CARBON DIOXIDE, WATER, WATER FOG/SPRAY, DRY
CHEMICAL, FOAM.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR SELF CONTAINED
BREATHING APPARATUS AND FULL PROTECTIVE GEAR. COOL TANKS AND
CONTAINERS EXPOSED TO FIRE WITH WATER.
Unusual Fire/Explosion Hazard:VAPOR IS FLAMMABLE AND HEAVIER THAN AIR
AND MAY TRAVEL TO SOURCE OF IGNITION AND FLASHBACK. STATIC
ELCTRICITY MAY ACCUMULATE AND IGNITE VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE POSSIBLE IGNITION SOURCES AND USE
NON-SPARKING TOOLS. MOP UP, WIPE UP OR SOAK UP WITH ABSORBENT
MATERIAL AND CONTAIN FOR SALVAGE OR DISPOSAL. CLEAN ANY REMAINING
SLIPPERY SURFACES BY APPROPRIAT E TECHNIQUES. USE PROPER PERSONNEL
PROTECTION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED AND AWAY FROM
HEAT, SPARKS AND OPEN FLAMES.
Other Precautions:AVOID EYE CONTACT. AVOID SKIN CONTACT. AVOID
BREATHING VAPOR. KEEP CONTAINER CLOSED. DO NOT TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURE MAY OR DOES EXCEED OCCUPATION
EXPOSURE LIMITS USE A NIOSH-APPROVED RESPIRATOR TO PREVENT
OVEREXPOSURE. IN ACCORD WITH 29 CFR 1910.134 USE EITHER AN
ATMOSPHERE-SUPPLYING RESPIRATOR OR AN AI R-PURIFYING RESPIRATOR.
Ventilation:LOCAL EXHAUST AND MECHANICAL (GENERAL) VENTILATION AS
REQUIRED TO MAINTAIN EXPOSURE LEVELS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
CONTAMINATED CLOTHING AND SHOES SHOULD BE REMOVED AS SOON AS PRACTICAL
AND THOROUGHLY CLEANED BEFORE REUSE.
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:NOT GIVEN
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Decomp Temp:Decomp Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:NOT GIVEN
Spec Gravity:0.97
Viscosity:> 50 CST
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:INSOLUBLE
Appearance and Odor:CHARCOAL GRAY LIQUID, SOLVENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL CAN CAUSE A REACTION.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NITROGEN OXIDES, METAL OXIDES, SULFUR
OXIDES, CARBON OXIDES , TRACES INCOMPLETELY BURNED CARBON
COMPOUNDS, FORMALDEHYDE
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LYSOL BRAND DISINFECTANT SPRAY LIGHT SCENT, 8Z0531
CAGE:DO879
CAGE:DO879
CAGE:73820
============= Composition/Information on Ingredients =============
Ingred Name:2-BIPHENYLOL; (ORTHO-PHENYLPHENOL)(SARA III)
CAS:90-43-7
RTECS #:DV5775000
Fraction by Wt: 0.1%
Ingred Name:CARBON DIOXIDE (PROPELLANT)
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: 4%
OSHA PEL:10000PPM; 30000STEL
ACGIH TLV:5000 PPM; 30000STEL
Ingred Name:ETHYL ALCOHOL; (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 79%
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: NONE EXPECTED. SUSCEPTIBLE
INDIVIDUALS MAY EXPERIENCE DIZZINESS, DROWSINESS, NAUSEA & VOMITING
IF EXPOSED TO EXTREMELY HIGH CONCENTRATIONS OF THE VAPORS. SKIN:
NONE EXPECTED. EYES: MAY CAUSE TE MPORARY EYE IRRITATION. INGEST:
INGESTION IS VERY UNLIKELY THROUGH THE NORMAL ANTICIPATED USE OF
THIS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:PRODUCT. INGESTION OF SMALL QUANTITIES
IS NOT EXPECTED TO CAUSE ANY SIGNIFICANT ADVERSE EFFECTS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE VICTIM TO FRESH AIR. SKIN:FLUSH W/COPIOUS
AMOUNTS OF WATER. CALL MD . EYES:FLUSH W/PLENTY OF LOW PRESSURE
WATER. REMOVE CONTACT LENSES TO INSURE A THOROUGH FLUSH & CONTINUE
TO FLUSH W/WATER FOR AT LEAST 15 MINS. IF IRRITATION PERSISTS, GET
MEDICAL ATTENTION. INGEST:ADMINISTER WATER TO DILUTE THE INGESTED
MATERIAL. CONSULT MD. DO NOT GIVE LIQUIDS TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:70.0F,21.1C
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEMICAL OR CARBON DIOXIDE.
USE MEDIA SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL PROT
EQUIP . MOVE CONTAINERS AWAY FROM FIRE IF POSS & SAFE TO DO SO. USE
WATER SPRAY TO COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CONTENTS UNDER PRESSURE. DO NOT USE NEAR
FIRE, SPARKS OR FLAME. DO NOT PUNCTURE OR INCINERATE CONTAINER.
EXPOSURE TO TEMPERATURES ABOVE 120F MAY CAUSE BURSTING.
================== Accidental Release Measures ==================
Spill Release Procedures:FOR LARGE SPILLS, ELIMINATE ALL IGNITION
SOURCES. VENTILATE THE AREA. COLLECT LIQUID & STORE IN SUITABLE
CONTAINERS FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY LOCATION AWAY
FROM HOT SURFACES, SPARKS OR FLAMES. CONTENTS UNDER PRESSURE. DO
NOT USE NEAR FIRE, SPARKS OR FLAME.
Other Precautions:EXPOSURE ABOVE 120F MAY CAUSE THE CONTAINER TO BURST.
KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:V3
Vapor Density:>1
Spec Gravity:0.835 @ 25C
Solubility in Water:MISCIBLE
Appearance and Odor:AEROSOL SPRAY CAN
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID TEMPERATURES ABOVE 120F.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE &
UNIDENTIFIED ORGANIC COMPOUNDS MAY BE FORMED DURING THERMAL
DECOMPOSITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SILVER CY-LESS COMPLEXOR C-1
CAGE:20816
CAGE:20816
============= Composition/Information on Ingredients =============
Ingred Name:SUCCINIMIDE, SUCCINIC IMIDE SUCCINIMIDE-SAUBA *96-3*
CAS:123-56-8
RTECS #:WN2200000
Fraction by Wt: >95%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: DUST IRRITANT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS/MORE. SKIN: WASH THOROUGHLY
W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. IF BREATHING
DIFFICULTIES DEVELOP, MAINTAIN RESPIRATION. INGESTION: INDUCE
VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:USE SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP INTO A STEEL DRUM.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE BETWEEN
55-85F. KEEP CONTAINER CLOSED.
Other Precautions:AVOID BREATHING DUST/PROLONGED CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED AIR PURIFYING RESPIRATOR
W/APPROPRIATE CARTRIDGE IN A MAJOR SPILL.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:SAFETY GLASSES W/SIDE SHIELDS/FACE SHIELD,
RUBBER APRON, LONG-SLEEVED SHIRTS
Work Hygienic Practices:WASH THOROUGHLY AFTER HANLDING. DON'T EAT,
DRINK/SMOKE IN THE WORK AREA.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:255F
Spec Gravity:1.418
Solubility in Water:COMPLETE
Appearance and Odor:CREAM COLORED TO COLORLESS FLAKES W/NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER & BASE MATERIALS
Stability Condition to Avoid:HEAT, OPEN FLAMES
Hazardous Decomposition Products:CARBON OXIDES, NITROGEN OXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN A WASTE SOLVENT SOLUTION IN A
FURNACE FITTED W/AN AFTER-BURNER & ALKALI SCRUBBER IN ACCORDANCE
W/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: TYPE 407 DEVELOPER (N-P), 78-6969-6128-9
Cage: 1BY21
=======================================================
Contractor Summary
=======================================================
Cage: 76381
Cage: 1BY21
=======================================================
Ingredients
=======================================================
Cas: 1317-61-9
% Wt: 90-99
OSHA PEL: 10 MG/M3
ACGIH TLV: 5 MG/M3
------------------------------
Cas: 27136-15-8
COPOLYMER)
% Wt: 1-5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: EYES: DUST MAY CAUSE SLIGHT IRRITATION. SKIN: NO
ADVERSE HEALTH EFFECTS ARE EXPECTED. INHALATION: DUST MAY CAUSE RESPIRATORY
SYSTEM IRRITATION. INGESTION: NO ADVERSE HEALTH EFFECTS ARE EXPECTED .
CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES: FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES AND CONTACT
MD. SKIN: FLUSH WITH COPIOUS AMOUNTS OF WATER. SEE MD (FP N). INHALATION: IF
RESPIRATORY IRRITATION OCCURS, MOVE TO FRESH AIR. INGE STION: CALL MD
IMMEDIATELY (FP N).
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: OBSERVE PRECAUTIONS IN OTHER SECTIONS. VACUUM, USE
WET SWEEPING COMPOUND OR WET DOWN WITH WATER TO AVOID DUSTING. POWDER LEFT ON
FLOOR WILL CREATE A SLIPPERY SURFACE.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF PRODUCT IN A SANITARY LANDFILL IN ACCORDANCE
WITH APPLICABLE REGULATIONS. DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS (FP N).
Handling And Storage Precautions: STORE AT ROOM TEMPERATURE. TEMPERATURES ABOVE
95F COULD CAUSE POWDER TO CLUMP.
Other Precautions: KEEP AWAY FROM HEAT, SPARKS, OPEN FLAMES, AND OTHER SOURCES
OF IGNITION.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: USE WATER SPRAY, CARBON DIOXIDE, DRY CHEM. THIS DEVELOPER
POWDER CONTAINS ONLY SLIGHT ATM OF COMBUST POLYMER. (SUP DAT)
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: AVOID CREATING A CONCENTRATED AIRBORNE DUST OF
THIS POWDER.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT REQUIRED UNDER NORMAL USE AND HANDLING. USE
NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN (FP N).
Ventilation: USE WITH NORMAL INDOOR VENTILATION.
Other Protective Equipment: EMERGENCY EYEWASH & DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: WASH HANDS AFTER HANDLING AND BEFORE EATING.
Supplemental Safety and Health: EXTING MEDIA: IT IS PRIMARILY NON-COMBUST IRON
OXIDE.
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 4.5 (H*2O=1)
Solubility in Water: NIL
Appearance and Odor: FINE POWDER, DARK GRAY IN COLOR, ESSENTIALLY ODORLESS
Percent Volatiles by Volume: NIL
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NONE KNOWN.
Hazardous Decomposition Products: NONE KNOWN.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: TYPE 407 DEVELOPER (N-P), 78-6969-6128-9
Cage: 1BY21
Company Name: MINNESOTA MINING AND MFG CO ENGINEERING DOCUMENT SYSTEMS DIV
Street: 3M CTR
Zipcode: 55144-1000
Label Required IND: Y
Date Of Label Review: 02/14/1996
Status Code: C
Label Date: 02/14/1996
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: EYES: DUST MAY CAUSE SLIGHT IRRITATION. SKIN: NO
ADVERSE HEALTH EFFECTS ARE EXPECTED. INHALATION: DUST MAY CAUSE RESPIRATORY
SYSTEM IRRITATION. INGESTION: NO ADVERSE HEALTH EFFECTS ARE EXPECTED .
CHRONIC: NONE SPECIFIED BY MANUFACTURER.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:74-6575, ETHANOL, 50%
Kit Part:Y
CAGE:59896
Contract Num:MDA414-00-P-4948
CAGE:59896
Contract Num:MDA414-01-P-2038
CAGE:59896
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ALCOHOL
CAS:64-17-5
RTECS #:KQ6300000
= Wt:47.5
OSHA PEL:1900 MG/M3;1000 PPM
ACGIH TLV:1880 MG/M3;1000 PPM
Ingred Name:METHYL ISOBUTYL KETONE
CAS:108-10-1
RTECS #:SA9275000
= Wt:1.9
OSHA PEL:410 MG/M3;100 PPM
ACGIH TLV:205 MG/M3;50 PPM
ACGIH STEL:307 MG/M3;75 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:HEXANE
CAS:110-54-3
RTECS #:MN9275000
= Wt:.6
OSHA PEL:1800 MG/M3;500 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE GIVEN FOR MIXTURE AS A WHOLE
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: SKIN, EYES, NOSE,
THROAT. EYE: MAY CAUSE IRRITATION. SKIN: MAY CAUSE IRRITATION.
INGESTION: MAY CAUSE GASTROINTESTINAL DISCOMFORT. INHALATION: MAY
CAUSE IRRITATION TO RESPIRATORY TRACT.
Explanation of Carcinogenicity:HEXANE, ETHYL ALCOHOL, METHYL ISOBUTYL
KETONE: NOT LISTED AS CAUSING CANCER BY IARC, NTP OR OSHA.
Effects of Overexposure:CONCENTRATIONS BELOW 1,000 PPM USUALLY PRODUCE
NO SIGNS OF INTOXICATION. EXPOSURE TO CONCENTRATIONS OVER 1,000 PPM
MAY CAUSE HEADACHE, IRRITATION OF THE EYES, NOSE, & THROAT, & IF
CONTINUED FOR AN HOU R, DROWSINESS & LASSITUDE, LOSS OF APPETITE &
INABILITY TO CONCENTRATE. EYES: IRRITATION. SKIN: IRRITATION.
INGESTION: INTESTINAL DISCOMFORT. INHALATION: RESPIRATORY
IRRITATION.
Medical Cond Aggravated by Exposure:PRE-EXISTING CONDITIONS OF THE
SKIN, EYES, THROAT, LIVER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES, RAISING/LOWERING LIDS.
GET MEDICAL ATTENTION IF IRRITATION PERSISTS. SKIN: THOROUGHLY WASH
EXPOSED AREA FOR AT LEAST 15 MINUTES. REMOVE CONTAMINATED CLOTHING.
LA UNDER CONTAMINATED CLOTHING BEFORE REUSE. GET MEDICAL ATTENTION
IF IRRITATION PERSISTS. INGESTION: IF CONSCIOUS, GIVE PLENTY OF
WATER. IMMEDIATELY CALL PHYSICIAN OR POISON CONTROL CENTER. NEVER
GIVE A NYTHING BY MOUTH TO UNCONSCIOUS PERSON. INHALATION: REMOVE
TO FRESH AIR. GIVE OXYGEN IF BREATHING DIFFICULT. GIVE ARTIFICIAL
RESPIRATION IF BREATHING STOPPED. KEEP PERSON WARM, QUIET AND GET
MEDICAL A TTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:=13.1C, 55.6F
ETHYL ALCOHOL
Autoignition Temp:=422.8C, 793.F
Lower Limits:3.3
Upper Limits:19
Extinguishing Media:USE DRY CHEMICAL, CO2 OR APPROPRIATE FOAM.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR FULL PROTECTIVE
EQUIPMENT & NIOSH APPROVED SELF CONTAINED BREATHING APPARATUS
Unusual Fire/Explosion Hazard:EXTREMELY FLAMMABLE. VAPORS ARE HEAVIER
THAN AIR & CAN TRAVEL DISTANCES TO IGNITION SOURCE & FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA OF SPILL. EMININATE ALL SOURCES
OF IGNITION. REMOVE ALL NON-ESSENTIAL PERSONNEL FROM AREA. CLEAN-UP
PERSONNEL SHOULD WEAR PROPER PROTECTIVE EQUIPMENT & CLOTHING.
ABSORB MATERIAL WITH SU ITABLE ABSORBANT & CONTAINERIZE FOR
DISPOSAL.
Neutralizing Agent:NO DATA PROVIDED BY RESPONSIBLE PARTY.
======================Handling and Storage ======================
Handling and Storage Precautions:THIS MATERIAL SHOULD BE KEPT IN AN
AREA SUITABLE FOR THE STORAGE OF FLAMMABLE LIQUIDS. BOND & GROUND
CONTAINERS WHEN TRANSFERRING LIQUID.
Other Precautions:KEEP OXIDIZING MATERIALS & STRONG ACIDS AWAY. WEAR
DURING CLEANUP PROCESS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH/MSHA CHEMICAL CARTRIDGE RESPIRATOR
SHOULD BE WORN IF PEL OR TLV IS EXCEEDED
Ventilation:LOCAL EXHAUST: YES. MECHANICAL (GENERAL): YES.
ALL TIMES.
Other Protective Equipment:LAB COAT, EYE WASH, AND SAFETY SHOWER
Work Hygienic Practices:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Supplemental Safety and Health
OTHER PRODUCT CODES: 74-6932, 74-6570. NOTE (DLA-HMIS): PRODUCT IS PART
OF A "TRANSPORTATION STUDENT KIT"; OTHER PART IS SERIAL NUMBER:
CKTRG.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:NO INFO AVAILABLE
Melt/Freeze Pt:M.P/F.P Text:NO INFO AVAILABLE
Vapor Pres:NO INFO AVAILABLE
Vapor Density:NO INFO
Spec Gravity:<1 (H20=1)
pH:NONE PROVIDED
Evaporation Rate & Reference:>1 (H20=1)
Solubility in Water:100%
Appearance and Odor:CLEAR LIQUID, FRUITY ODOR
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE
Conditions to Avoid Polymerization:WILL NOT OCCUR
=================== Toxicological Information===================
Toxicological Information:TOXICITY DATA: TO THE BEST OF OUR KNOWLEDGE,
THE TOXICOLOGICAL PROPERTIES OF THIS MIXTURE HAVE NOT BEEN
THOROUGHLY EVALUATED. DATA IS LISTED FOR THE INDIVIDUAL COMPONENTS.
ETHYL ALCOHOL: ORL-RAT LD50: 7.060 MG/KG. IHL-RAT LC50: 20,000
PPM/10H; METHYL ISOBUTYL KETONE: ORL-RAT LD50: 5.080 MG/KG. IHL-RAT
LC50: 8,000 PPM/4 HR. HEXANE: ORL-RAT LD50: 28.710 MG/KG; IHL-HMN
TCLO: 5,000 PPM/10M. EFFECTS OF OVER EXPOSURE: SEE ACUTE. CHRONIC:
ETHYL ALCOHOL: MUTATION DATA CITED. REPRODUCTIVE EFFECTS DATA
CITED. TUMORIGENIC DATA CITED. HEXANE: MUTATION DATA CITED.
REPRODUCTIVE DATA CITED. METHYL ISOBUTYL K ETONE: NO CHRONIC
EFFECTS FOUND.
===================== Ecological Information =====================
Ecological:EPA WASTE NUMBERS: METHYL ISOBUTYL KETONE (U161) IS
CONSIDERED A HAZARDOUS WASTE IF AND WHEN IT IS DISCARDED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE & LOCAL REGULATIONS. ALWAYS CONTACT A PERMITTED
WASTE DISPOSER (TSD) TO ASSURE COMPLIANCE.EPA WASTE NUMBERS:
METHYL ISOBUTYL KETONE (U161) IS CONSIDERED A HAZARDOUS WASTE IF &
WHEN IT IS DISCARDED.
=================== MSDS Transport Information ===================
Transport Information:ETHYL ALCOHOL SOLUTIONS. 3. UN1170. II. REQUIRED
LABEL(S): FLAMMABLE LIQUID.
===================== Regulatory Information =====================
SARA Title III Information:SARA EHS (SEC 302, TPQ): NONE. SARA SEC 313
CHEMICALS (LIST): METHYL ISOBUTYL KETONE, SARA SEC 313 CHEMICALS
(CATEGORY): NONE. HAZARD CATEGORY FOR SARA SECTION 311/312
REPORTING: ACUTE, FIRE.
Federal Regulatory Information:CERCLA SEC 103 RQ: METHYL ISOBUTYL
KETONE-5000 LBS. RCRA SECTION 261.33: METHYL ISOBUTYL KETONE. EPA
TSCA LIST: ON TSCA LIST.
State Regulatory Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: PR 12, POLYESTER FINISHING RESIN
Cage: 8W247
Box: 1246
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 8W247
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: YES
OSHA: NO
Effects of Exposure: ACUTE:STYRENE AT 400 PPM OR IN STRONG CONCENTRATIONS IS
IRRITATING TO ALL PARTS OF RESPIRATORY TRACT AND EYES. MAY BE FATAL AT 10,000
PPM. SOMEWHAT ANESTHETIC. STYRENE VAPOR RARELY EXCEEDS 200 PPM, FR OM
POLYESTER RESIN. CHRONIC:ALLERGIC SENSITIVITY CAN RESULT FROM CONTINUOUS
EXPOSURE.
Explanation Of Carcinogenicity: STYRENE:IARC MONOGRAPHS, SUPPLEMENT, VOL 7, PG
345, 1987:GROUP 2B. ANIMAL:NERVOUS SYSTEM.
Signs And Symptions Of Overexposure: INHAL:DIZZINESS, FAINT FEELING, COMA AT
EXTREME LEVELS. CONTACT WITH SKIN/EYES:LOCAL IRRITATION, PAIN OR ITCHING.
SKIN ABSORPTION:LOCAL IRRITATION, PAIN OR ITCHING. INGESTION:NAUSEA,
VOMITING, COMA.
Medical Cond Aggravated By Exposure: RESPIRATIORY ALLERGIES, CHRONIC
RESPIRATORY TRACT IRRITATION, SKIN SENSITIVITY. RECOMMENDATIONS TO PHYSICIAN.
First Aid: EYES:FLUSH PROMPTLY WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST 15
MINUTES AND SEEK MEDICAL ATTENTION. SKIN:WASH AFFECTED AREA WITH SOAP AND
WATER, REMOVE SATURATED CLOTHING. INHALATION:REMOVE TO WELL- VENTILATED AREA,
MAKE COMFORTABLY WARM BUT NOT HOT. USE OXYGEN OR ARTIFICIAL RESPIRATION AS
NEEDED. INGESTION:DO NOT INDUCE VOMITING. CALL A PHYSICIAN IMMEDIATELY.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE SATURATED CLOTHING PROMPTLY AND WASH AFFECTED
AREAS WITH SOAP AND WATER. REMOVE ALL SOURCES OF IGNITION. VENTILATE AREA.
ABSORB WITH INERT MATERIALS SUCH AS VERMICULITE AND PLACE IN CLOSED CONT
AINER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: INCINERATE IN AN APPROVED INCINERATOR OR DISPOSE OF IN
A CHEMICAL DUMP. DISPOSE OF ALL WASTES IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.
Handling And Storage Precautions: AVOID IMPROPER ADDN OF PROMOTER &/OR
CATALYST. PROMOTER & CATALYST USED W/THIS PROD SHOULD ALWAYS BE MIXED
SEPARATELY W/PROD & NEVER MIXED TOGETHER.
Other Precautions: AVOID STOR >100F. AVOID PRLNGD SKIN CONT & INHAL OF
HEATED VAPS/SPRAY MIST. HOW TO DETECT SUBSTANCE:(WARNING PROPERTIES OF
SUBSTANCE AS GAS, VAP, DUST/MIST). NOXIOUS ODOR FROM VAPOR. AVOID CONTACT WIT
H SPRAY MIST.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: SCC
Flash Point Text: 89.0F,31.7C
Extinguishing Media: FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: STYRENE POLYMERIZED READILY AT ELEVATED
TEMPERATURES OF FIRE CONDITIONS. IF THIS OCCUR IN A CLOSED CONTAINER, VIOLENT
RUPTURE IS POSSIBLE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: MUST BE WORN TO PREVENT INHALATION OF HEATED VAPORS,
SPRAY MISTS OR IF TLV IS EXCEEDED.
Ventilation: PROVIDE GENERAL DILUTION OR LOCAL EXHAUST VENTILATION TO COMPLY
WITH INGREDIENTS AND FIRE AND EXPLOSION DATA.
Other Protective Equipment: SAFETY SHOWER AND EYE WASH STATIONS SHOULD BE
AVAILABLE.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: EYE PROT:AND FULL LENGTH FACE SHIELD (FP N).
=======================================================
Physical/Chemical Properties
=======================================================
HCC: F4
B.P. Text: 295F,146C
Vapor Density: 3.6
Spec Gravity: 1.05-1.22 @ 25C
Solubility in Water: NEGLIGIBLE
Appearance and Odor: PURPLE OPAQUE LIQUID WITH A PUNGENT ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEAT AND DIRECT SUNLIGHT.
Materials To Avoid: NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products: CO*2, CARBON MONOXIDE, LOW MOLECULAR WEIGHT
HYDROCARBONS AND ORGANIC ACIDS.
Hazardous Polymerization Indicator: YES
Conditions To Avoid Polymerization: SUNLIGHT, OPEN FLAME AND CONTAMINATION.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: PR 12, POLYESTER FINISHING RESIN
Cage: 8W247
Company Name: DETCO MARINE
Street: UNKNOWN
Zipcode: 92663
Label Required IND: Y
Date Of Label Review: 04/11/1995
Status Code: C
Label Date: 04/11/1995
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE. ACUTE: STYRENE AT 400 PPM OR IN STRONG
CONCENTRATIONS IS IRRITATING TO ALL PARTS OF RESPIRATORY TRACT AND EYES. MAY
BE FATAL AT 10,000 PPM. SOMEWHAT ANESTHETIC. STYRENE VAPOR RARELY EXCEEDS
200 PPM, FROM POLYESTER RESIN. INHALATION: DIZZINESS, FAINT FEELING, COMA AT
EXTREME LEVELS. SKIN/EYES: LOCAL IRRITATION, PAIN OR ITCHING. SKIN
ABSORPTION: LOCAL IRRITATION, PAIN OR ITCHING. INGESTIO N: NAUSEA, VOMITING,
COMA. CHRONIC: CANCER HAZARD: MONOSTYRENE IS LISTED AS A LUNG AND LIVER
CARCINOGEN TO LABORATORY ANIMALS (FP N). ALLERGIC SENSITIVITY CAN RESULT FROM
CONTINUOUS EXPOSURE.
=======================================================
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: HIPEC R 6101 SEMICONDUCTOR PROTECTIVE COATING
Cage: 5D028
=======================================================
Contractor Summary
=======================================================
Cage: 5D028
Box: 997
Cage: 71984
=======================================================
Ingredients
=======================================================
Cas: 68083-19-2
% Wt: 82
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 68909-20-6
% Wt: 15
Other REC Limits: 5 MG/M3, C (MFR)
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 63148-57-2
% Wt: 1
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
ALL PERSONAL PROT EQUIP RECS DESCRIBED
-----------------------------
TO SPILLS/RELS OF THIS MATL INTO ENVIRON.
-----------------------------
IGNIT SOURCES & IF NEEDED, USE NONSPARKING
-----------------------------
ABSORB, ETC, USED DURING CLEANUP ONLY IN
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:EYE:DIRECT CONT MAY CAUSE TEMPORARY DISCOMFORT
W/MILD REDNESS & DRYNESS SIMILAR TO WINDBURN. SKIN:SINGLE PRLNG EXPOS
(24-48 HRS) CAUSES NO KNOWN ADVERSE EFT. INHAL:NO IRRIT TO EYES & RESP
PASSAG ES. NO INJURY IS LIKELY FROM RELATIVELYSHORT EXPOS OF <8 HRS.
INGEST:SM AMTS TRANSFERRED TO MOUTH BY (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:FINGERS DURING USE, ETC, SHOULD
NOT INJURE. SWALLOWING LG AMTS MAY CAUSE DIGEST DISCOMFORT. CHRONIC:NONE
KNOWN.
Medical Cond Aggravated By Exposure: OVEREXPOSURE TO ANY CHEMICAL MAY RESULT IN
ENHANCEMENT OF PRE-EXISTING ADVERSE MEDICAL CONDITIONS & ALLERGIC
REACTIONS.
First Aid: TREAT SYMPTOMATICALLY. INGEST:CALL MD IMMEDIATELY (FP N).
INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP) (FP N).
SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD (FP N). EYE:IMMEDIATE LY FLUSH
W/WATER FOR AT LEAST 15 MINUTES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: MOP UP/WIPE UP/SOAK UP W/ABSORB & CONTAIN FOR
SALVAGE/DISP. FOR LG SPILLS, PROVIDE DIKING/OTHER APPROP CONTAINMENT TO KEEP
MATL FROM SPREADING. CLEAN ANY REMAINING SLIPPERY SURFS BY APPROP TECHNIQUES,
SUCH AS:SEVERAL MOPPINGS/SWABBINGS W/ (SUPP DATA)
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL OF COLLECTED PRODUCT, RESIDUES & CLEANUP
MATERIALS MAY BE GOVERNMENTALLY REGULATED. OBSERVE ALL APPLICABLE LOCAL,
STATE & FEDERAL WASTE MANAGEMENT REGULATIONS.
Handling And Storage Precautions: THESE PRECS ARE FOR ROOM TEMP HNDLG. USE AT
ELEVATED TEMP OR AEROSOL/SPRAY APPLICATIONS, MAY REQ ADDED PRECS. AVOID EYE
CONTACT. USE REAS CARE.
Other Precautions: TRACES OF FORMALDEHYDE (CARCIN) MAY FORM IF HEATED IN AIR
>300F (149C). PROVIDE VENT TO CONTROL VAP EXPOS W/IN INHAL GUIDELINES WHEN
HNDLG AT ELEVATED TEMPS. REVIEW OSHA FORMALDEHYDE REGS FOR DETAILED INFO ON
SAFE HNDLG REQUIREMENTS.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: 145F,63C
Extinguishing Media: CARBON DIOXIDE (CO*2), WATER, WATER FOG (OR SPRAY), DRY
CHEMICAL, FOAM.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). IF LARGE AMOUNT IS INVOLVED, EVACUATE AREA.
Unusual Fire/Explosion Hazard: VAPS ARE HVR/AIR & CAN TRAVEL ALONG GROUND
TO REMOTE IGNIT SOURCES. STATIC ELEC MAY ACCUM & IGNITE VAPS. PVNT POSS
FIRE HAZ BY SUITABLE MEANS, SUCH AS, (SUPDAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N). NO RESPIRATORY PROECTION SHOULD BE NEEDED.
Ventilation: LOCAL EXHAUST:NONE SHOULD BE NEEDED. GENERAL
VENTILATION:RECOMMENDED.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: WASHING AT MEALTIME & END OF SHIFT IS ADEQUATE.
Supplemental Safety and Health: EXPLO HAZ:BONDING & GROUNDING, INERT GAS
PURGE, VAP DILUTION & THE LIKE. MATLS TO AVOID:PROD, LIBERATE FLAMM
HYDROGEN GAS, WHICH CAN FORM EXPLO MIXTS IN AIR. SPILL PROC:APPROP SOLVS;
WASHING W/MILD, C AUSTIC DETERGENTS/SOLNS; OR HIGH PRESS STEAM FOR LG AREAS.
FOR NONSILICONES, USE TYPICAL INDUS CLEANING MATLS.
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 1.04
Solubility in Water: NONE
Appearance and Odor: LIQUID.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE.
Materials To Avoid: OXIDIZING MATL CAN CAUSE RXN. WATER, ALCOHOLS, ACIDIC/BASIC
MATLS & MANY METALS/METALLIC CMPDS, WHEN IN CONT W/ (SUPDAT)
Hazardous Decomposition Products: CARBON OXIDES & TRACES OF INCOMPLETELY BURNED
CARBON COMPOUNDS. SILICON DIOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: HIPEC R 6101 SEMICONDUCTOR PROTECTIVE COATING
Cage: 5D028
Company Name: DOW CORNING CORP
Street: 3901 S SAGINAW RD
PO Box: 997
Zipcode: 48686-0997
Label Required IND: Y
Date Of Label Review: 07/20/1995
Status Code: C
Label Date: 07/20/1995
Origination Code: G
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE LIQUID. ACUTE:EYE:DIRECT CONTACT MAY CAUSE
TEMPORARY DISCOMFORT W/MILD REDNESS & DRYNESS SIMILAR TO WINDBURN.
SKIN:SINGLE PROLONGED EXPOSURE (24-48 HOURS) CAUSES NO KNOWN ADVERSE EFFECT.
I NHAL:NO IRRITATION TO EYES & RESPIRATORY PASSAGES. NO INJURY IS LIKELY
FROM RELATIVELY SHORT EXPOSURE OF <8 HOURS. INGEST:SMALL AMOUNTS
TRANSFERRED TO MOUTH BY FINGERS DURING USE, ETC, SHOULD NOT INJU RE.
SWALLOWING LARGE AMOUNTS MAY CAUSE DIGESTIVE DISCOMFORT. CHRONIC:NONE LISTED
BY MANUFACTURER.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:F2226S CHLORAMBEN METHYL ESTER 100UG/ML IN ACETONE:ISOOCTANE
CAGE:84898
CAGE:84898
CAGE:8Y898
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE
CAS:67-64-1
RTECS #:AL3150000
OSHA PEL:750 PPM
ACGIH TLV:750 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOOCTANE
CAS:540-81-1
RTECS #:SA3320000
OSHA PEL:500 PPM
ACGIH TLV:383 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT/MOUSE): 5800 MG/KG (SUPP)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACETONE: INHALATION:
HARMFUL/RESPIRATORY TRACT IRRITATION/MUCOUS MEMBRANE IRRITATION.
SKIN: HARMFUL IF ABSORBED/IRRITATION/DERMATITIS. EYES: IRRITATION.
INGESTION: HARMFUL. ISOOCTANE: INGESTIION: HARM FUL. INHALATION:
HARMFUL/MUCOUS MEMBRANE IRRITATION. EYES: IRRITATION. SKIN: MAY BE
HARMFUL IF ABSORBED/IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:ACETONE: IRRITATION. ISOOCTANE: IRRITATION.
======================= First Aid Measures =======================
First Aid:ACETONE-EYES: FLUSH W/WATER FOR 15-20 MINS. SKIN: FLUSH
W/WATER FOR 15-20 MINS. IFNOT BURNED, WASH W/SOAP & WATER.
INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED. KEEP
WARM/QUIET. INGEST ION: INDUCE VOMITING W/SYRUP OF IPECAC.DON'T
GIVE LIQUIDS/INDUCE VOMITING IF UNCONSCIOUS/CONVULSING. IF VOMITING
OCCURS, WATCH CLOSELY TO AVOID AIRWAY OBSTRUCTION. (SEE SUPP)
===================== Fire Fighting Measures =====================
Flash Point:-0.4F (SEE SUPP)
Lower Limits:2.6 (SUPP)
Upper Limits:12.8 (SUPP)
Extinguishing Media:CO2, DRY CHEMICAL POWDER/SPRAY.
Unusual Fire/Explosion Hazard:FLAMMABLE CHEMICAL. ACETONE: VAPORS MAY
TRAVEL TO DISTANT IGNITION SOURCE & FLASH BACK. SENSITIVE TO HEAT.
AUGTOIGNITION TEMP: 869F.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR APPRORPRIATE OSHA
REGULATED EQUIPMENT. VENTILATE AREA. ABSORB ON VERMICULITE/SIMILAR
MATERIAL. SWEEP UP & PLACE IN APPROPRIATE CONTAINER/HOLD FOR
DISPOSAL. WASH CONTAMINATED SURFAC ES TO REMOVE ANY RESIDUES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL DRY PLACE ONLY
W/COMPATIBLE CHEMICALS. KEEP TIGHTLY CLOSED. FOR LABORATORY USE
ONLY.
Other Precautions:AVOID CONTACT W/SKIN, EYES & CLOTHING. DON'T BREATH
VAPORS. CONTACT LENSES SHOULDN'T BE WORN IN THE LABORATORY. ALL
CHEMICALS SHOULD BE CONSIDERED HAZARDOUS. AVOID DIRECT PHYSICAL
CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE OSHA/MSHA APPROVED SAFETY
EQUIPMENT.
Ventilation:CHEMICAL SHOULD BE HANDLED ONLY IN A HOOD.
Work Hygienic Practices:ACETONE: REMOVE/LAUNDER CONTAMINATED CLOTHING
BEFORE REUSE.
Supplemental Safety and Health
FIRST AID CONT'D: ISOOCTANE: EYES: FLUSH W/WATER FOR 15-20 MINS. SKIN:
FLUSH W/WATER FOR 15-20 MINS. IF NOT BURNED, WASH W/SOAP & WATER.
INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED. OBT AIN
MEDICAL ATTENTION IN ALL CASES. ALLPHYSICAL/FIRE/ORAL LD50
INFORMATION IS FOR ACETONE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:133.7F SUPP
Melt/Freeze Pt:M.P/F.P Text:-137.2F
Vapor Pres:184 (SUPP)
Vapor Density:2 (SUPP)
Evaporation Rate & Reference:(BU AC =1): 5.6 (SUPP)
Solubility in Water:MISCIBLE (SUPP)
Appearance and Odor:COLORLESS LIQUID W/FRUITY/PLEASANT ODOR. (SEE SUPP)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACETONE: STRONG ACIDS/OXIDIZING AGENTS/BASES/REDUCING AGENTS.
Stability Condition to Avoid:HEAT.
Hazardous Decomposition Products:TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED W/AN
AFTERBURNER & SCRUBBER IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:1235 SOLDERING FLUID
CAGE:84311
CAGE:84311
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 65%.
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:ROSIN
Fraction by Wt: 35%.
Ingred Name:ETHANOLAMINE
CAS:141-43-5
RTECS #:KJ5775000
Fraction by Wt: 0.09%
OSHA PEL:3 PPM/6 STEL
ACGIH TLV:3 PPM/6 STEL; 9192
===================== Hazards Identification =====================
Effects of Overexposure:ACTS AS A LOCAL IRRIT.AT HIGH CONCENTRATIONS AS
A NARCOTIC.
======================= First Aid Measures =======================
First Aid:SKIN/EYE:IMMEDIATELY FLUSH W/WATER FOR AT LEAST 15 MIN.
INAHL:REMOVE TO FRESH AIR. CALL DR.IF NEEDED.
===================== Fire Fighting Measures =====================
Flash Point:55F OC
Lower Limits:2.5
Upper Limits:12
Extinguishing Media:CO*2,DRY CHEM.
Fire Fighting Procedures:DRUMS EXPOSED TO HEAT SHLD BE COOLED W/WATER.
KEEP UPWIND
Unusual Fire/Explosion Hazard:DANGEROUS WHEN EXPOSED TO HEAT OR FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILL:ADD WATER OR ABSORBENT.LARGE
SP.EXTINGUISH ALL FLAMES,EVACUATE AREA,OPEN WINDOWS AND DOORS.ADD
ABSORBENT
======================Handling and Storage ======================
Handling and Storage Precautions:NONE OTHER THAN THOSE COMMENSURABLE
WITH GOOD PRACTICE AD GOOD HOUSEKEEPING.
Other Precautions:KEEP VAPORSBELOW 400 PPM DURING SOLDERING.
============= Exposure Controls/Personal Protection =============
Ventilation:LOCAL-DURING SOLDER.MECHANICAL EXPLOSION PROOF.
Supplemental Safety and Health
MFG SUGGESTS TLV OF 400 PPM.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:180F
Vapor Pres:33.
Vapor Density:2.07
Spec Gravity:0.885
Evaporation Rate & Reference:1.7,BUTYL ACETATE
Solubility in Water:APPRECIABLE
Appearance and Odor:AMBER-ETHEREAL
Percent Volatiles by Volume:82.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CAN REACT VIGOROUSLY WITH OXIDIZING MATERIAL
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR PLACE ABSORBENT INTO RUBBISH DUMP
CART. (MFG RECOMMENDATION)
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:2,4-DIAMINOPHENOL DIHYDROCHLORIDE, G261
CAGE:DO803
CAGE:DO803
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:PHENOL, 2,4-DIAMINO-, DIHYDROCHLORIDE; (2,4-DIAMINOPHENOL
DIHYDROCHLORIDE)
CAS:137-09-7
RTECS #:SK7600000
Fraction by Wt: 90-100%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: IRRITATION OF UPPER
RESPIRATORY TRACT. SKIN/EYE: SEVERE IRRITATION OR BURNS. SKIN
ABSORPTION: MAY BE HARMFUL. INGEST: IS HARMFUL AND MAY BE FATAL,
IRRITATION AND BURNS TO MOUTH AND STOMA CH. CHRONIC: BLOOD DAMAGE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE IDENTIFIED.
======================= First Aid Measures =======================
First Aid:INGEST:CALL PHYS. IF SWALLOWED, DO NOT INDUCE VOMIT. IF
CONSCIOUS, GIVE LG AMT OF H2O. INHAL: REMOVE TO FRESH AIR. IF NOT
BRTHG, GIVE ARTF RESP. IF BRTHG IS DIFFICULT, GIVE O2. SKIN: IMMED
FLUSH WITHPLENTY OF WATER FOR AT LEAST 15 MIN WHILE REMOVING
CONTAMINATED CLOTHING AND SHOES. WASH CLOTHING BEFORE RE-USE. EYE:
IMMED FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MIN.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:TOXIC GASES: AMMONIA, HYDROGEN CHLORIDE,
OXIDES OF NITROGEN, CO, CO2.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SCBA AND FULL PROTECTIVE CLOTHING. WITH
CLEAN SHOVEL, CAREFULLY PLACE MATERIAL INTO CLEAN, DRY CONTAINER
AND COVER; REMOVE FROM AREA. FLUSH SPILL AREA WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN CORROSION-PROOF AREA. KEEP CONTAINERS OUT OF SUN AND AWAY FROM
HEAT.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHERE ADEQ VENT CONDITIONS EXIST.
IF AIRBORNE CONC IS HIGH, NIOSH/MSHA APPROVED CHEMICAL CARTRIDGE
RESPIRATOR W/ ACID/ORGANIC CARTRIDGE IS RECOMMENDED. IF CONC
EXCEEDS CAPACITY OF CARTRI DGE RESPIRATOR, SCBA IS ADVISED.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
FUME OR DUST LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:UNIFORM, APRON.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:401F,205C
Solubility in Water:APPRECIABLE(>10%)
Appearance and Odor:OFF-WHITE CRYSTALLINE POWDER.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES, STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, LIGHT.
Hazardous Decomposition Products:HYDROGEN CHLORIDE, AMMONIA, OXIDES OF
NITROGEN, CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE, AND LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ANTIFREEZE/COOLANT
Preparer's Name:DOD-HMIS (DGSC-SSH)
CAGE:33958
CAGE:5V280
CAGE:33958
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 95%
Other REC Limits:NONE SPECIFIED
OSHA PEL:C 50 PPM
ACGIH TLV:C 50 PPM,VAPOR;9091
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ADDITIVE PACKAGE
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ACUTE ORAL LD50 (RAT) IS 8540 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: MAY CAUSE IRRITATION.
SKIN: MAY CAUSE SLIGHT IRRITATION. INHALATION: VAPORS OR MISTS MAY
CAUSE IRRITATION OF THE NOSE & THROAT. INGESTION: TOXIC WITH
DELAYED SYMPTOMS. CHRONIC: PROLONGED SKIN CONTACT MAY RESULT IN
ABSORPTION AND MORE SEVERE IRRITATION. REPEATED INGESTION MAY CAUSE
KIDNEY DAMAGE AND DEATH.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYE AND SKIN IRRITATION. INHALATION OF VAPORS
OR MISTS MAY CAUSE HEADACHE, NAUSEA, AND DROWSINESS. INGESTION
CAUSES HEADACHE, WEAKNESS, CONFUSION, LOSS OF COORDINATION,
DIZZINESS, NAUSEA, VOMITING, DE CREASED BLOOD PRESSURE, INCREASED
HEARTRATE, PULMONARY EDEMA, KIDNEY FAILURE, UNCONSCIOUSNESS,
CONVULSIONS, AND COMA.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF KIDNEY
DISORDERS MAYBE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. CALL A PHYSICIAN IF
DISCOMFORT PERSISTS. EYE: IMMEDIATELY FLUSH EYES WITH PLENTY OF
WATER FOR 15 MINUTES. CALL A PHYSICIAN. SKIN: WASH WITH PLENTY OF
SOAP & WATER. REM OVE CONTAMINATED CLOTHING/SHOES. INGESTION: IF
CONSCIOUS, GIVE 2 GLASSES OF WATER TO DRINK AND INDUCE VOMITING.
GIVE NOTHING BY MOUTH IF UNCONSCIOUS. CALL A PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:244F,118C
Lower Limits:3.2
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL. WATER OR FOAM MAY CAUSE FROTHING.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. AVOID BREATHING VAPOR. USE
SELF-CONTAINED BREATHING APPARATUS OR SUPPLIED AIR FOR LARGE SPILLS
OR CONFINED AREAS. CONTAIN SPILL IF POSSIBLE. WIPE UP OR ABSORB ON
SUITABLE MATERIAL AND SHOVEL UP. PREVENT ENTRY INTO SEWERS &
WATERWAYS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:MINIMUM FEASIBLE HANDLING TEMPERATURES
SHOULD BE MAINTAINED. PERIODS OF EXPOSURE TO HIGH TEMPERATURES
SHOULD BE MINIMIZED. AVOID WATER CONTAMINATION.
Other Precautions:ACUTE OR CHRONIC ORAL CONSUMPTION OF PRODUCTS
CONTAINING ETHYLENE GLYCOL CAN PRODUCE SIGNIFICANT ADVERSE HEALTH
EFFECTS, INCLUDING DEATH. KEEP OUT OF REACH OF CHILDREN AND PETS.
DO NOT USE IN POTABLE WATER SYSTEMS. MINIMIZE ALL EXPOSURES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL(TLV), USE NIOSH/MSHA APPROVED ORGANIC VAPOR
CARTRIDGE AND DUST/MIST PRE-FILTER RESPIRATORS AS PER CURRENT 29
CFR 1910.134, INSTRUCTIONS/ WARNINGS AND NIOSH-RESPIRATOR
SELECTION.
Ventilation:MECHANICAL (GENERAL) ROOM VENTILATION IS ADEQUATE IF USE IS
ENCLOSED. LOCAL EXHAUST IS NEEDED IF VENTED INTO WORK AREA.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL- TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
MSDS COPIED FROM ANOTHER MANUFACTURER'S OF THE SAME SPEC MATERIAL. **
DO NOT TAKE INTERNALLY. DO NOT GET ON SKIN OR IN EYES. AVOID
PROLONGED OR REPEATED BREATHING OF VAPOR. DO NOT BREATHE MISTS. WAS
H THOROUGHLY AFTER HANDLING AND BEFORE EATING OR DRINKING OR
SMOKING OR USING REST ROOM.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:388F,198C
Vapor Pres:<0.1
Vapor Density:2.14
Spec Gravity:1.13
pH:10.8
Solubility in Water:COMPLETE
Appearance and Odor:SLIGHTLY HAZY BLUE-GREEN LIQUID
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
DO NOT ADD OR FORMULATE WITH AMINES.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE.
BORON, MOLYBDENUM AND SILICON COMPOUNDS MAY ALSO BE RELEASED.
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS PRODUCT DOES NOT MEET THE CRITERIA OF A
HAZARDOUS WASTE IF DISCARDED IN ITS PURCHASED FORM. IT IS THE
RESPONSIBILITY OF THE USER OF THE PRODUCT TO DETERMINE AT THE TIME
OF DISPOSAL, WHETHER THE P RODUCT MEETS RCRA CRITERIA FOR HAZARDOUS
WASTE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:1031101 ELECKTRA
CAGE:FO503
CAGE:94746
CAGE:FO503
============= Composition/Information on Ingredients =============
Ingred Name:SILVER (SARA III)
CAS:7440-22-4
RTECS #:VW3500000
Fraction by Wt: 58.50%
Other REC Limits:10 UG/CUM
OSHA PEL:0.01 MG/M3
ACGIH TLV:0.1 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:INDIUM
CAS:7440-74-6
RTECS #:NL1050000
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.1 MG/M3; 9192
Ingred Name:COPPER (SARA III)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 14.50%
Other REC Limits:1 MG(CU)/M3 (DUST)
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2MG/M3 FUME; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
Medical Cond Aggravated by Exposure:WILSON'S DISEASE (COPPER)
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE TO FRESH AIR, OXYGEN OR ART. RESPIRATION IF
NEEDED. INGESTION: DILUTE W/WATER, SEEK MEDICAL ATTENTION. EYES:
FLUSH W/WATER FOR 20 MINUTES, SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP/VACUUM SOLIDS, DON'T RAISE DUST.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CREATING FUMES OR DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHILE GRINDING
Ventilation:USE LOCAL EXHAUST VENTILATION
Other Protective Equipment:APRONS
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:1590-1810F
Spec Gravity:10.4
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE-LIGHT GOLD
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:SALVAGE/REUSE DISPOSE ACCORDING TO LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:NICKEL SULFATE
CAGE:82925
CAGE:82925
============= Composition/Information on Ingredients =============
Ingred Name:NICKEL SULFATE HEXAHYDRATE
CAS:10101-97-0
RTECS #:QR9600000
Fraction by Wt: > 99.0%
Other REC Limits:NONE SPECIFIED BY M.
OSHA PEL:0.1 MG/M3 (NI)
ACGIH TLV:0.1 MG/M3 (NI); 8990
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS 275 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-INHALATION:IRRITATION OF UPPER
RESPIRATORY TRACT. SKIN:IRRITATION, SENSITIZATION. EYES:IRRITATION.
INGESTION:IRRITATION OF GI TRACT., MAY BE HARMFUL IN LARGE
QUANTITIES. CHRONIC: DERMATITIS, CON JUCTIVITIS.
Explanation of Carcinogenicity:NTP & IARC INDICATE SUFFICIENT EVIDENCE
OF NICKEL AND CERTAIN NICKEL COMPOUNDS TO BE SUSPECTED CARCINOGENS
EXEPT NISO4.
Effects of Overexposure:INHALATION:COUGHING. SKIN:IRRITAION, ITCHING.
EYES:REDNESS, TEARING, PAIN. INGESTION: EPIGASTIRIC PAIN, WEAKNESS,
DELERIUM, CONVULSIONS.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
FOR 15 MINUTES HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION.
SKIN:REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER. IF
IRRITATION PERSISTS, GET MEDICAL ADVICE. INGESTION:INDUCE VOMITING.
GIVE LARGE QUATITIES OF WATER IF CONSCIOUS. GET IMMEDIATE MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE CARBON DIOXIDE, HALON, FOAM, DRY CHEMICAL, OR
WATER FOG.
Fire Fighting Procedures:MOVE CONTAINER FROM FIRE AREA IF POSSIBLE. DO
NOT SCATTER SPILLED MATERIAL WITH HIGH PRESSURE WATER STREAMS. DIKE
FOR LATER DISPOSAL.
Unusual Fire/Explosion Hazard:NONE. USE AGENTS SUITABLE FOR TYPE OF
SURROUNDING FIRE. AVOID BREATHING HAZARDOUS VAPORS OR DUSTS, KEEP
UPWIND.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH APPROVED RESPIRATOR. SHOVEL UP INTO
CONTAINERS FOR DISPOSAL. VACUUM UP RESIDUE. DO NOT FLUSH TO SEWER
OR WATERWAY.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY AREA. KEEP
CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT CONTAINERS FROM
PHYSICAL DAMAGE.
Other Precautions:DO NOT TAKE INTERNALLY. AVOID PROLONGED OR REPEATED
BREATHING OF DUST. AVOID CONTACT WITH EYES. USE WITH ADEQUATE
VENTILATION. WASH THOROUGHLY AFTER HANDLING. FOR INDUSTRIAL USE
ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL(TLV), USE NIOSH/MSHA APPROVED DUST/MIST
PRE-FILTER RESPIRATORS AS PER CURRENT 29 CFR 1910.134,
INSTRUCTIONS/WARNINGS AND NIOSH-RESPIRATO R SELECTION.
Ventilation:MECHANICAL (GENERAL) ROOM VENTILATION IS NORMALLY ADEQUATE.
LOCAL EXHAUST MAY BE REQUIRED IF WORK AREA NOT VENTED.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT WEAR CONTACT LENSES UNDER DUSTY CONDITIONS..
================== Physical/Chemical Properties ==================
HCC:V1
Melt/Freeze Pt:M.P/F.P Text:128F,53C
Vapor Pres:0.0
Spec Gravity:2.07
Solubility in Water:40% @ 20C
Appearance and Odor:BLUE OR EMERALD GREEN, CRYSTALS, ODORLESS
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE TOXIC AND HAZARDOUS SULFUR OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:317-1162 7002 SATIN FINISH VARNISH
CAGE:54636
CAGE:26290
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9495
Ingred Name:VM & P NAPHTHA (LIGHT ALIPHATIC PETROLEUM SOLVENT NAPHTHA)
CAS:64742-89-8
Fraction by Wt: 7%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHYL BENZENE (SARA 313)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/125STEL;9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS) (SARA 313) (CERCLA)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 16%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE (SARA 313) (CERCLA)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 45%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:750PPM/1000STEL;9495
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VOLATILE ORGANIC CONTENT: AS A WEIGHT PERCENT BY BAAQMD
RULE 49.
RTECS #:9999999VO
Fraction by Wt: 90%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EXPOSURE MAY CAUSE EYE, SKIN &
RESPIRATORY TRACT IRRITATION. INHALATION MAY CAUSE CNS DEPRESSION.
CHRONIC: PROLONGED OR REPEATED EXPOSURE MAY CAUSE NERVE TISSUE
DAMAGE, ADVERSE EFFECTS TO LIVER
/URINARY/BLOOD-FORMING/CARDIOVASCULAR/REPRODUCTIVE SYSTEMS;
PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:INHALED-HEADACHE, DIZZINESS, NAUSEA, LOSS OF
COORDIANTION. SKIN/EYES-REDNESS, ITCHING, BURNING SENSATION.
OTHER-MUSCULAR WEAKNESS, LOSS OF SENSATION.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHALED-REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM &
QUIET. SKIN-WASH THOROUGHLY WITH SOAP & WATER. EYES-FLUSH WITH LOTS
OF WATER FOR 15 MINUTES. GET MEDICAL ATTENTION. IF INGESTED-GET
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:<0F,<-18C
Lower Limits:0.9
Upper Limits:13.1
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM. WATER SPRAY MAY
BE INEEFECTIVE, IF WATER USED, USE FOG NOZZLE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE GEAR. COOL FIRE EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. APPLICATION TO HOT SURFACES REQUIRES
SPECIAL PRECAUTIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. VENTILATE
AND REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM SOURCES OF IGNITION.
VAPORS WILL ACCUMULATE READILY AND MAY IGNITE EXPLOSIVELY. KEEP
AREA VENTILATED.
Other Precautions:CONTENTS UNDER PRESSURE DO NOT PUNCTURE, INCINERATE,
OR EXPOSE TO TEMPERATURES ABOVE 120F. HEAT FROM SUNLIGHT,
RADIATORS, STOVES, HOT WATER AND OTHER HEAT SOURCES MAY CAUSE
CONTAINER TO BURST. DO NOTTAKE INTERNALLY. KEEP AWAY FROM
CHILDREN
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE
OR AN EMERGENCY OCCURS; WEAR AN MSHA/NIOSH APPROVED RESPIRATOR WITH
ORGANIC VAPOR CARTRIDGE OR AN AIR-SUPPLIED RESPIRATOR OR SCBA, AS
REQUIRED. USE IAW 29 CFR 1910.134.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION OR LOCAL EXHAUST TO
MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER. DLA-HMIS:
EYE WASH.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND INHALAING THE
CONTENTS CAN BE HARMFUL OR FATAL. NOTE: DLA-HMIS STAFF ASSUMED
AEROSOL CAN BECAUSE MSDS READ "MISCELLANEOUS SPRAYS-2" PLUS BUYER
STAT ES ON DGSC FORM P-75 "11 OZ CAN". MSDS PRESENTED BY CAGE 26290
FOR CONTRACT NUMBER MDA414-96P-5947.
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:0F,-18C
Vapor Density:>1
Evaporation Rate & Reference:>1 (ETHER=1)
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE-CARBON MONOXIDE AND CARBON
DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THIS PRODUCT MAY BE HAZARDOUS IAW
RCRA 40 CFR 261. WASTE MUST BE TESTED FOR IGNITABILITY TO DETERMINE
THE APPLICABLE EPA HAZARDOUS WASTE NUMBERS. DO NOT INCINERATE.
DEPRESSURIZE CONTAINER.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:IPA-ANHYDROUS
Resp. Party Other MSDS Num.:90275000
CAGE:72190
Contract Num:SP0450-99-M-NB66
CAGE:032U8
CAGE:4N760
CAGE:72190
CAGE:86511
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPYL ALCOHOL (SARA 313)
CAS:67-63-0
RTECS #:NT8050000
= Wt:99.8
Other REC Limits:NONE RECOMMENDED
OSHA PEL:400 PPM
ACGIH TLV:400 PPM/500STEL;9495
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) = 5840 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:EYE CONTACT IRRITATING, WILL INJURE
EYE TISSUE IF NOT REMOVED PROMPTLY. SKIN: FREQUENT OR PROLONGED
CONTACT MAY CAUSE IRRITATE & CAUSE DERMATITIS. LOW ORDER OF
TOXICITY. INGESTION: MAY CAUSE GI TRACT IRRITATION. MAY CAUSE
BRONCHIOPNEUMONIAOR PULMONARY EDEMA IF ASPIRATED DURING INGESTION
OR VOMITING. INHALATION: MAY CAUSE RESPIRATORY IRRITATION & CENTRAL
NERVOUS SYSTEM EFFECTS. NEGLIGIBLE HAZARD WH EN AT AMBIENT
TEMPERATURE.
Explanation of Carcinogenicity:NONE SPECIFIED BY MANUFACTURER.
Effects of Overexposure:EYES: IRRITATION. SKIN: IRRITATION, DERMATITIS.
INHALATION: RESPIRATORY TRACT IRRITATION, HEADACHES, DIZZINESS.
INGESTION: NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN: REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP & WATER.
EYES: FLUSH WITH WATER FOR 15 MINUTES. GET MEDICAL ATTENTION.
INHALATION: USING RESPIRATORY PROTECTION, REMOVE VICTIM TO FRESH
AIR.ADMINIS TER ARTIFICIAL RESPIRATION IF BREATHINGSTOPPED.
INGESTION: DO NOT INDUCE VOMITING. KEEP AT REST. GET PROMPT MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:=12.2C, 54.F
Autoignition Temp:>350.C, 662.F
Lower Limits:2.0
Upper Limits:12.7
Extinguishing Media:ALCOHOL TYPE FOAM OR DRY CHEMICAL.TRY TO COVER
LIQUID SPILLS WITH FOAM.
Fire Fighting Procedures:USE WATER SPRAY TO COOL FIRE EXPOSED SURFACES
AND TO PROTECT PERSONNEL.SHUT OFF "FUEL" TO FIRE.IF A LEAK OR SPILL
HAS NOR IGNITED,USE WATER SPRAY TO DISPERSE THE VAPORS. EITHER
ALLOW FIRE TO BURN UNDE R CONTROLLED CONSIDERATIONS OR EXTINGUISH
WITH ALCOHOL TYPE FOAM AND DRY CHEMICAL.TRY TO COVER LIQUID SPILLS
WITH FOAM.
Unusual Fire/Explosion Hazard:FLAMMABLE LIQUID. CAN RELEASE VAPORS THAT
FORM FLAMMABLE MIXTURES AT TEMPERATURES AT OR ABOVE FLASHPOINT.
"EMPTY" CONTAINERS RETAIN PRODUCT RESIDUES AND CAN BE DANGEROUS.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE SOURCES OF IGNITION. USE PROPER
RESPIRATORY & PROTECTIVE EQUIPMENT. VENTILATE AREA. RECOVER BNY
PUMPING (HAND PUMP OR EXPLOSION-PROOF). SOAK UP WITH A NON-
COMBUSTIBLE, INERT ABSORBANT (EART H, SAND). PLACE IN PROPER
CONTAINER FORDISPOSAL. PREVENT LIQUID FROM ENTERING SEWERS,
WAERCOURSES OR LOW AREAS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT. STORE IN COOL
PLACE. KEEP BOTTLE TIGHTLY CLOSED. KEEP FROM EYES.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE CONCENTRATIONS IN AIR MAY EXCEED THE
LIMITS GIVEN AND ENGINEERING,WORK PRACTICE OR OTHER MEANS OF
EXPOSURE REDUCTION ARE NOT ADEQUATE. NIOSH/MSHA APPROVED
RESPIRATORS MAY BE NECESSARY TO PREVEN T OVEREXPOSURE BY
INHILATION.
Ventilation:MECHANICAL DILUTION VENTILATION IS RECOMMENDED WHENEVER
THIS PRODUCT IS USED IN CONFINED SPACE,USE EXPLOSION-PROOF
VENTILATION EQUIPMENT
Other Protective Equipment:LONG SLEEVES WHERE CONTACT IS LIKELY.
Work Hygienic Practices:DO NOT TAKE INTERNALLY. AVOID SKIN CONTACT.
WASH SKIN AFTER USING PRODUCT. DO NOT EAT, DRINK OR SMOKE IN WORK
AREA.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:=82.2C, 180.F
B.P. Text:TO 181 F
Melt/Freeze Pt:=-88.7C, -128.F
Vapor Pres:96@100
Spec Gravity:0.79
Viscosity:3 CST @ 68F
Evaporation Rate & Reference:2.3 (NBUAC=1)
Solubility in Water:COMPLETE (100% @ 68F)
Appearance and Odor:CLEAR,COLORLESS LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CAUSTICS, AMINES, ALKANOLAMINES, ALDEHYDES, STRONG OXIDIZING AGENTS,
CHLORINATED COMPOUNDS.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:NONE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:ACUTE TOXICITY DATA IS AVAILABLE ON REQUEST.
CHRONIC TOXICITY: IN DEVELOPMENTAL TOXICITY STUDIES CONDUCTED BY
THE CHEMICAL MANUFACTURER'S ASSOCIATION, UNEXPECTED ACUTE TOXICITY
WAS FOUND WHEN ISOPROP ANOL WAS ADMINISTERED TO PREGNANT RABBITS BY
GAVAGE. THERE WERE NO UNEXPECTED ACUTE TOXIC EFFECTS IN PREGNANT
RATS EXPOSED IN THE SAME STUDY. IN RATS THERE WERE SOME RELATIVELY
MILD DEVELOPMENTAL EFFE CTS IN MATERNALLY TOXIC LEVELS. THERE WAS
NO EVIDENCE OF DEVELOPMENTAL TOXICITY IN THE RATS AT LEVELS WHICH
DID NOT PRODUCE MATERNAL TOXICITY.
===================== Ecological Information =====================
Ecological:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ALL WASTE IN ACCORDANCE WITH LOCAL,
STATE AND FEDERAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:US DOT SHIPPING DESCRIPTION: ISOPROPANOL, 3,
UN1219, II.
===================== Regulatory Information =====================
SARA Title III Information:SECTIONS 311/312: IMMEDIATE HEALTH, DELAYED
HEALTH, FIRE. THIS INFORMATION MAY BE SUBJECT TO THE PROVISIONS OF
THE COMMUNITY RIGHT-TO-KNOW REPORTING REQUIREMENTS (40 CFR 370) IF
THRESHOLD QUANTITY CRI TERIA ARE MET.
Federal Regulatory Information:TSCA: THIS PRODUCT IS LISTED ON THE TSCA
INVENTORY AT CAS REGISTRY NUMBER 67-63-0. CERCLA: IF THIS PRODUCT
IS ACCIDENTLY SPILLED, IT IS NOT SUBJECT TO ANY SPECIAL REPORTING
UNDER THE REQUIREMENTS OF T HE COMPREHENSIVE ENVIRONMENTAL
RESPONSE,COMPENSATION AND LIABILITY ACT (CERCLA). WE RECOMMEND YOU
CONTACT LOCAL AUTHORITIES TO DETERMINE IF THERE MAY BE OTHER LOCAL
REPORTING REQUIREMENTS.
State Regulatory Information:NONE SPECIFIED BY MANUFACTURER.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:K-300
CAGE:019K5
CAGE:019K5
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:REPEATED OR PROLONGED EXPOSURE MAY
CAUSE SKIN AND EYE IRRITATION. HARMFUL IF SWALLOWED. NO KNOWN
TOXICITY INFORMATION IS AVAILABLE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . SKIN:REMOVE CONTAMINATED
CLOTHING. WASH SKIN WITH SOAP & WATER FOR 5 MINUTES. EYES:FLUSH WI
TH COPIOUS AMOUNTS OF WATER FOR AT LEAST 15 MINUTES.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE . K-300 IS A
NON-FLAMMABLE LIQUID.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE AND ABSORB SPILL WITH INERT MATERIAL SUCH
AS SAND, EARTH OR VERMICULITE AND TRANSFER TO A SUITABLE CONTAINER
FOR DISPOSAL. FLUSH AREA WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL PRECAUTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NONE REQUIRED.
Ventilation:LOCAL EXHAUST:RECOMMENDED.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Supplemental Safety and Health
SPEC GRAV:1.34 +/- 0.1 (H*2O=1).
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:100F,38C
Spec Gravity:SUPP DATA
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID WITH NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH ALKALIS. PRECIPITATION MAY OCCUR.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:AT TEMPERATURES OF 500F, HYDROGEN
CHLORIDE GAS WILL BE LIBERATED.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN A FURNACE OR BURY IN AN APPROVED
LANDFILL ACCORDING TO FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:803 CROWN LATEX ARCHITECTURAL COATING
CAGE:85207
CAGE:72556
CAGE:85207
============= Composition/Information on Ingredients =============
Ingred Name:VOLATILE ORGANIC CONTENT: <200 G/L
RTECS #:9999999VO
Ingred Name:CALCIUM CARBONATE, DOMOLITE, LIMESTONE, WHITING *97-2*
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 5%
Other REC Limits:5 MG/M3 RESP DUST
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/CUM TOTAL DUST
Ingred Name:CRYSTALLINE-QUARTZ SILICA, SILICA DUST (SUSPECTED HUMAN
CARCINOGEN BY IARC-GROUP 2A; SUSPECTED CARCINOGEN NTP) *97-2*
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <5%
Other REC Limits:0.05 MG/CUM (NIOSH)
OSHA PEL:10 MG/CUM %RESP SIO2
ACGIH TLV:0.1 MG/CUM RESP DUST
Ingred Name:SILICA CRYSTALLINE, SILICA (CRISTOBALITE) (SUSPECTED HUMAN
CARCINOGEN BY IARC, SUSP CARC BY NTP; IARC GROUP 2A) *97-2*
CAS:14464-46-1
RTECS #:VV7325000
Fraction by Wt: <5%
Other REC Limits:0.05 MG/CUM NIOSH
ACGIH TLV:0.05 MG/CUM
Ingred Name:ETHYLENE GLYCOL *97-2*
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: <5%
Other REC Limits:10 MG/CUM
OSHA PEL:50 PPM
ACGIH TLV:C 127 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ETHYLENE OXIDE (SUSP HUMAN CARCINOGEN BY ACGIH, IARC, SUSP
CARC BY NTP; OSHA CANCER HAZARD; IARC - GROUP 1) *97-2*
CAS:75-21-8
RTECS #:KX2450000
Fraction by Wt: <0.1%
ACGIH TLV:1.8 MG/CUM (A2)
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:FORMALDEHYDE, FORMALIN (SUSPECTED HUMAN CARCINOGEN BY IARC;
ACGIH; SUSPECTED CARCINOGEN BY NTP; IARC - GROUP 2A) *97-2*
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: <0.1%
ACGIH TLV:0.37 MG/CUM IC (2A)
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:1,2-PROPANEDIOL (PROPYLENE GLYCOL)
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: <5%
Ingred Name:AMORPHOUS SILICA GEL, SILICON DIOXIDE *97-2*
CAS:7631-86-9
Fraction by Wt: 10%
Ingred Name:PROPANOIC ACID, 2-METHYL, MONOESTER
W/2,2,4-TRIMETHYL-1,3-PENTANEDIOL, TEXANOL(ESTER ALCOHOL)
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: <5%
Ingred Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
CARCINOGEN, IARC GROUP 3)*97-2*
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 15%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:VINYL ACETATE
CAS:108-05-4
RTECS #:AK0875000
Fraction by Wt: <0.1%
Other REC Limits:10 PPM
ACGIH TLV:35 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-(2-BUTOXYETHYOXY)-ETHANOL, DIETHYLENE GLYCOL MONOBUTYL
ETHER (BUTYL CARBITOL) *97-2*
CAS:112-34-5
RTECS #:KJ9100000
Fraction by Wt: <5%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 9500 MG/KG (SEE SUPP)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:PRIMARY IRRITANT. HAZARDS OF
INDIVIDUAL INGREDIENTS; EYE: IRIDOCYCLITIS, BURNS, POSSIBLE
PERMANENT DAMAGE. SKIN: BURNS, DERMATITIS. INHALATION: LUNG INJURY,
CNS DEPRESSION, SILICOSIS, PNEUMONIA, EDEMA . INGESTION: CNS
EFFECTS, GI TRACT IRRITATION. ADVERSE REPRODUCTIVE EFFECTS &
CHROMOSOME DAMAGE. (SEE SUPP)
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:IRRITATION, ECZEMA-LIKE CONDITION, DEFATTING,
HEADACHE, NAUSEA, VOMITING, DIFFICULTY BREATHING, DIZZINESS, COUGH,
CYANOSIS, DROWSINESS, PAIN, DIARRHEA, UNCONSCIOUSNESS
Medical Cond Aggravated by Exposure:LUNG DISEASE, SKIN & RESPIRATORY
CONDITIONS.
======================= First Aid Measures =======================
First Aid:INGESTION: DRINK 2 GLASSES OF WATER & INDUCE VOMITING BY
PLACING FINGER AT BACK OF THROAT. NEVER GIVE ANYTHING BY MOUTH TO
AN UNCONSCIOUS PERSON. INHALATION: REMOVE TO FRESH AIR. RESTORE
BREATHING. EY ES: FLUSH W/COOL WATER FOR 15 MINS. SKIN: WASH
THOROUGHLY W/SOAP & WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:>200F
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP & REMOVE W/INERT ABSORBENT MATERIAL.
PROVIDE ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE APPROVED MECHANICAL RESPIRATOR OR MASK TO
AVOID BREATHING SPRAY MISTS.
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME & PATTERN TO KEEP
BELOW TLV.
Other Protective Equipment:PROTECTIVE OVERALLS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. DISCARD CONTAMINATED SHOES.
Supplemental Safety and Health
THIS IS A LATEX PAINT. PRIMARY HEALTH HAZARD IS POSSIBLE IRRITATION TO
EYES & SKIN. HEALTH HAZARDS ARE FOR EACH INGREDIENT. LD50
INFORMATION IS FOR TITANIUM DIOXIDE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Vapor Density:<1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:65
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:EXTREME HEAT
Hazardous Decomposition Products:CO, CO2, NITROGEN OXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T INCINERATE IN CLOSED CONTAINERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FIBERGLASS FABRIC, 218
CAGE:1B420
CAGE:1B420
============= Composition/Information on Ingredients =============
Ingred Name:FIBROUS GLASS (TEXTILE GRADE)
Fraction by Wt: 99.94%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:RESPIRABLE FIBROUS GLASS DUST
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:ORGANICALLY BOUND SILANES
Fraction by Wt: 0.4%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: DIRECT SKIN CONTACT WITH
FIBROUS GLASS OR ITS DUST MAY CAUSE MECHANICAL IRRITATION AND
TRANSITORY DERMATITIS. BREATHING OF FIBERS OR DUST MAY CAUSE
MECHANICAL IRRITATION OF THE MOUTH, NOSE, AND THROAT. CHRONIC:
NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE TO FRESH AIR AREA. INGESTION: NOT LIKELY TO
OCCUR THROUGH NORMAL USE. CALL MD IMMEDIATELY . EYES: FLUSH WITH
FLOWING WATER FOR AT LEAST 15 MINUTES. SKIN: FLUSH WITH AMPLE COLD
W ATER FOLLOWED BY WASHING WITH MILD SOAPTO REMOVE ACCUMULATED
FIBERS.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, DRY POWDER, OR FOAM (NEEDED FOR PACKAGING
ONLY).
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:DUST OR LOOSE FIBERS CAN BE VACUUMED OR SWEPT
WITH THE AID OF A DUST SUPPRESSANT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN DRY AREA.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF AIRBORNE DUST OR FIBERS EXCEED THE TLV OR IF
UPPER RESPIRATORY IRRITATION OCCURS, USE A NIOSH APPROVED
RESPIRATOR DESIGNED FOR NUISANCE TYPE DUSTS.
Ventilation:NORMAL AREA VENTILATION IS SUFFICIENT IN MOST CASES TO KEEP
DUST AND FIBER LEVELS BELOW THE TLV.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:2.5
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE SOLID; NO DISTINCTIVE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE GENERATED UNDER NORMAL STORAGE OR
HANDLING CONDITIONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE ACCORDING TO LOCAL, STATE, AND FEDERAL
LAWS. THIS MATERIAL IS NOT REGULATED UNDER RCRA HAZARDOUS WASTE
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:15/413/18 SPECTRO KIT N/NITRATE
CAGE:EO812
CAGE:27847
CAGE:EO812
============= Composition/Information on Ingredients =============
Ingred Name:CADMIUM (SARA III)
CAS:7440-43-9
RTECS #:EU9800000
Fraction by Wt: <25%
OSHA PEL:SEE 1910.1027
ACGIH TLV:0.01 MG/M3 DUST;9394
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
Effects of Overexposure:HEADACHE/CHILLS/MUSCLE
ACHES/NAUSEA/VOMITING/DIARRHEA/EMPHYSEMA/PROTEINURIA/ANOSMIA & MILD
ANEMIA.
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE TO FRESH AIR. SKIN CONTACT: WASH WITH WATER.
EYE CONTACT: IMMEDIATELY FLUSH WITH WATER FOR 15 MINUTES.
INGESTION: DRINK WATER, CALL A PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS
Unusual Fire/Explosion Hazard:EVOLVES CADMIUM OXIDE FUME
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM, MINIMIZE DUSTING.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP DRY, COOL
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED DUST RESP IF EXPOSURE EXCEEDS
>TLV.
Ventilation:PROVIDE LOCAL EXHAUST VENTILATION TO KEEP BELOW TLV.
Supplemental Safety and Health
MSDS DATE: 24 JAN 1985.
================== Physical/Chemical Properties ==================
Spec Gravity:2.00
Solubility in Water:SOLUBLE
Appearance and Odor:GRAY POWDER
Percent Volatiles by Volume:0%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:MOISTURE
Hazardous Decomposition Products:CADMIUM OXIDE, NOX, SOX
==================== Disposal Considerations ====================
Waste Disposal Methods:FEDERAL, LOCAL AND STATE REGULATION.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ZAK, DN4080
CAGE:64557
CAGE:64557
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 70-80%
OSHA PEL:2 MG/M3, C
ACGIH TLV:2 MG/M3, C
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SODIUM (I) NITRATE (1:1); (SODIUM NITRATE)
CAS:7631-99-4
RTECS #:WC5600000
Fraction by Wt: 10-20%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED CONTACT MAY CAUSE BURNS TO
EYES AND SKIN. INGESTION IS CORROSIVE TO SOFT TISSUE. TARGET ORGANS
AFFECTED: VAPORS: IRRITATING TO EYES AND RESPIRATORY TRACT. DIRECT
CONTACT: IRRITATING TO SKIN AND EYES.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:BRONCHIAL IRRITATION FROM DUSTS OR
FUMES.
======================= First Aid Measures =======================
First Aid:SKIN: WASH THOROUGHLY WITH SOAP AND WATER. EYES: IMMEDIATELY
FLUSH WITH PLENTY OF WATER FOR AT 30 MIN & CALL MD. INHAL: REMOVE
TO FRESH AIR. INGEST: DO NOT INDUCE VOMIT. GIVE LARGE AMOUNTS OF
WATER. G IVE AT LEAST ONE OUNCE OF VINEGAR OR LEMON JUICE IN AN
EQUAL AMOUNT OF WATE.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Extinguishing Media:EXTINGUISHING MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:GENERATES LARGE AMOUNTS OF HEAT UPON CONTACT
WITH WATER. WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:WATER CONTACT GENERATES LARGE AMOUNTS OF
HEAT (AND NOXIOUS GASES).
================== Accidental Release Measures ==================
Spill Release Procedures:IMMED WEAR APPROP PROTECTIVE CLOTHING. SHOVEL
UP MATERIAL & RETURN TO CONTAINERS, FINAL RESIDUES MAY BE FLUSHED
WITH COPIOUS AMOUNTS OF WATER. KEEP SPILLED MATERIAL OUT OF
WATERWAYS AND SEWERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF THE REACH OF CHILDREN.
KEEP CNTNR CLOSED WHEN STORING. AVOID ALL SKIN & EYE CNTCT. STORE
IN A COOL DRY AREA AWAY FROM ACIDS.
Other Precautions:PROTECT CONTENTS FROM MOISTURE. DO NOT ADD WATER TO
THE CNTNR. NEVER USE W/ACID-BASED DRAIN CLEANERS. USE IN VENT
AREAS. AVOID BRTHG FUMES GENERATED WHILE USING THIS PROD. READ
COMPLETE LABEL FOR USE CAUTION DIRECTIONS BEFORE USING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:TO AVOID EXCESSIVE INHALATION A NIOSH/MSHA
APPROVED RESPIRATOR IS RECOMMENDED.
Ventilation:LOCAL EXHAUST: FRESH AIR.
Other Protective Equipment:LONG SLEEVES, LONG PANTS &/OR APRON
IMPERVIOUS TO THE INGREDIENTS IN THIS PROD. EMERGENCY EYE WASH &
DELUGE SHOWER
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING THE WASHROOM.
SMOKE -- IN SMOKING AREAS ONLY.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Density:HVR/AIR
Spec Gravity:1.2
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:COMPLETE
Appearance and Odor:RED BEADED SOLID, NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTS WITH WATER PRODUCING EXTREME HEAT.
Stability Condition to Avoid:CONTACT WITH ACIDS, ACID SOLUTIONS, SOFT
METALS & MOISTURE.
Hazardous Decomposition Products:WHEN HEATED TO DECOMPOSITION, CAN EMIT
TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:ACCORDING TO LOCAL POLLUTION ORDINANCES FOR
STRONGLY ALKALINE, CORROSIVE SOLIDS. DISPOSAL MUST BE IN ACCORDANCE
WITH FEDERAL, STATE AND LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:KA FORMULA H D HAND CLEANER, 8460
Preparer's Name:RONALD A WILLIAMS
CAGE:02905
CAGE:02905
============= Composition/Information on Ingredients =============
Ingred Name:NON HAZARDOUS INGREDIENTS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. INGEST: GASTRIC
DISTRESS.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MINS, IF IRRIT PERSISTS,
CONTACT MD OR POISON CONTROL CENTER. INGEST: DO NOT INDUCE
VOMITING, CONTAINS ISOPARAFFIN, CONTACT MD OR POISON CONTROL CENTER
IMMEDIATELY. SKIN: FLUSH W/COPIOUS AMOUNTS OF WATERFOR AT LEAST 15
MINS. INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP).
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>140F,>60C
Extinguishing Media:WATER FOG, ALCOHOL FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB & COLLECT FOR DISPOSAL. FLUSH AREA WITH
WATER TO REDUCE POSSIBLE FLOOR "SLIP" HAZARD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID EYE CONTACT; STORE AT AMBIENT
CONDITIONS.
Other Precautions:NONE KNOWN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED. NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE REQUIRED.
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:ROUTINE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:0.9 (H*2O=1)
Solubility in Water:45%
Appearance and Odor:AMBER OPAQUE GEL, PLEASANT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:ACCORDING TO ALL LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:T Y 3864; THINNER
CAGE:19898
CAGE:18873
CAGE:19898
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 6%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ALIPHATIC PETROLEUM DISTILLATE
Fraction by Wt: 87%
ACGIH TLV:100 PPM (MFR)
Ingred Name:AROMATIC PETROLEUM DISTILLATE
Fraction by Wt: 7%
ACGIH TLV:100 PPM (MFR)
Ingred Name:1-METHYL-1-PHENYLETHYL HYDROPEROXIDE (CUMENE HYDROPEROXIDE)
(SARA III)
CAS:80-15-9
RTECS #:MX2450000
Fraction by Wt: 0.33%
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
Effects of Overexposure:HEADACHE, NAUSEA, IMPAIRMENT OF REACTION TIME &
COORDINATION.
======================= First Aid Measures =======================
First Aid:INH: MOVE TO FRESH AIR TO IMPROVE BRTHNG. SKIN: WAS W/SOAP &
WATER. REMOVE CONTAM CLOTHING. EYE: FLUSH W/WATER FOR AT LEAST 15
MIN. CALL MD.
===================== Fire Fighting Measures =====================
Flash Point:20-73F CC
Lower Limits:1.0
Upper Limits:7.0
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL
Fire Fighting Procedures:WATER FOG MAY BE USED TO COOL CANS, PREVENT
PRESSURE BUILDUP
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID PROLONGED CONTACT W/SKIN & BRTHNG OF
VAPOR. REMOVE SOURCES OF IGNITION. REMOVE W/INERT ABSORBENT.
VENTILATE AREA.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & OPEN
FLAME. CLOSE CONTAINER AFTER EACH USE. DO NOT STORE ABOVE 120F.
Other Precautions:WASH THOROUGHLY AFTER HANDLING & BEFORE EATING OR
SMOKING. GROUND CONTAINER WHEN POURING. OBSERVE LABEL PRECAUTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPRVD RESP DEVICE IF NEC.
Ventilation:SUFFICIENT TO KEEP BELOW TLV/LEL LEVELS. REMOVE IGNIT
SOURCE
Other Protective Equipment:USE APPROPRIATE INDUSTRIAL HYGIENE PRACTICES
Supplemental Safety and Health
VAPOR PRESSURE & VAPOR DENSITY ARE BASED ON THE PRINCIPLE SOLVENT. THE
FLAM LIMITS ARE APPROX. INGRED PERCENTAGES ARE APPROX.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:190-426F
Vapor Pres:10
Vapor Density:2.5
Spec Gravity:0.754
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIQUID THINNER W/CHARACTERISTIC ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE REASONABLE FORESEEABLE (MFR)
Hazardous Decomposition Products:CO, CO*2, SMOKE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IAW FED., STATE & LOCAL CODES.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MIL-C-46168D PART B 4:1 BLEND
Kit Part:Y
Preparer's Name:MICHAEL J LICHATOWICH
CAGE:02388
CAGE:02388
============= Composition/Information on Ingredients =============
Ingred Name:HOMOPOLYMER OF HDI
CAS:28182-81-2
RTECS #:NQ9170000
Fraction by Wt: 75%
Other REC Limits:NONE SPECIFIED
Ingred Name:HEXAMETHYLENE DIISOCYANATE *(RESIDUAL MONOMER
CONTENT LESS THAN 0.5% BASED ON RESIN SOLIDS AT TIME OF MFR.**
CAS:822-06-0
RTECS #:MO1740000
Fraction by Wt: *
Other REC Limits:NONE SPECIFIED
ACGIH TLV:0.005 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:**AFTER 3-6 MO STORAGE, THE FREE MONOMER CONTENT MAY RISE
(MAX 1.6). MFR ALSO RECOMMENTS A CEILING LEVEL OF 0.02 PPM.
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
Ingred Name:XYLENE (SARA 313) (VAPOR PRESSURE 7.0 MM HG @ 20C)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 12.5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:N-BUTYL ACETATE (VAPOR PRESSURE 10 MM HG @ 20C)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 12.5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM
ACGIH TLV:150 PPM/200 PPM STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VOC: 2.21 LB/GL
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL 4,300 MG/KG RAT. INHAL ***
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: IRRIT, REDUCED LUNG FUNCTION
(BREATHING OBSTRUCTION),LUNG DAMAGE, BRONCHITIS, BRONCHIAL SPASM,
PULMONARY EDEMA. CHEMICAL/HYPERSENSITIVE PNEUMONITIS. EYE, NOSE,
THROAT IRRIT. HIGH CONC CAN CAUSE DEATH. SOME INDIVIDUALS MAY
DEVELOP ISOCYANATE SENSITIZATION (LATER REACT W/EXPOS BELOW TLV).
MORE INFORMATION ON FILE.
Explanation of Carcinogenicity:N/K ***137 TO 1150 MG/M3 RAT. DERMAL
LD50 >1,700 MG/KG RABBIT.
Effects of Overexposure:BURNING SENSATION (NOSE, THROAT, LUNGS), RUNNY
NOSE, SORE THROAT, COUGHING, WHEEZING, ASTHMATIC ATTACK, LUNG
SENSITIVITY, CHEST DISCOMFORT, SHORTNESS OF BREATH, FEVER, CHILLS.
DRYNESS (THROAT), TIGHTN ESS (CHEST). HEADACHE, NAUSEA, NARCOSIS,
FATIGUE, LOSS OF APPETITE. REDNESS, RASH, SWELLING, SCALING,
BLISTERING. ****
Medical Cond Aggravated by Exposure:ASTHMA & OTHER RESPIRATORY
DISORDERS (BRONCHITIS, EMPHYSEMA, HYPERREACTIVITY), SKIN ALLERGIES,
ECZEMA. ****LOSS OF
COORDINATION, LOSS OF INTELLECTUAL ABILITY.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE TO FRESH AIR. ADMIN OXYGEN/ARTIF RESP. CALL DR.
ASTHMATIC SYMPTOMS? TREAT SYMPTOMATICALLY. CALL DR. SKIN:REMOV
CONTAM CLOTH. WASH W/SOAP & WTR. SEVERE EXPOS, REMOVE CLOTH, GET
UNDER SAFETY SHOWER. CALL DR. LESSER EXPOS-CALL DR, IF IRRIT
DEVELOPS. EYE:FLUSH W/WTR 15 MIN, LIFT LIDS. REFER TO DR. INGEST:NO
VOMIT. 1-2 CUPS MILK/WATER. NOTHING BY MOUTH TO UNCONSCIOUS/CONVULS
PERSON. CALL DR.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:91.0F,32.8C
Lower Limits:1.0
Upper Limits:7.6
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:FULL EMERG EQUIP (SCBA & FULL PROTECT CLOTH).
DURING FIRE, HDI & OTHER TOXIC GASSES MAY BE GENERATED. ISOLATE
FROM IGNIT SOURCE. CLSD CNTNR MAY EXPLODE W/HEAT.*
Unusual Fire/Explosion Hazard:*CLSD CNTNR MAY BURST WHEN CONTAM W/WATER
CREATING CO2. SOLVENT VAPOR HEAVIER THAN AIR, MAY TRAVEL ALONG
GROUND TO IGNITION SOURCE & FLASHBACK TO VAPOR SOURCE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVAC PEOPLE. REMOVE IGNIT SOURCES. VENT.
DIKE/STOP SPILL. NOTIFY AUTHORITIES. COVER SPILL W/ABSORB/DECONTAM
SOLUTION ON SPILL, LET REACT 10 MIN. COLLECT PROD IN CNTNR, COVER
LOOSELY, STAND 24 HR. WASHSPILL W/DECOMTAM. RESPIRATOR PROTECT
RECOMMENDED.
Neutralizing Agent:DECONTAM SOLUTIONS: NONIONIC SURFACTANT TERGITOL
TMN-10(20%) WATER(80%);#
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE: MINIMUM -30F/122F MAX. KEEP
FROM IGNITION SOURCE/HEAT. GRND CNTNRS DURING STORAGE/TRANSFER.
STORE IN CLSD CNTNRS. DO NOT RESEAL IF CONTAM.
Other Precautions:AVOID CONTACT W/SKIN & EYES. USE OF POS PRESS AIR
SUPP RESP MAY BE NECESSARY FOR MIXING OR BRUSH APPLICATION. SEE
ADDITIONAL INFORMATION ON FILE. FOLLOW LABEL INSTRUCT.
#CONCENTRATED AMMONI A (3-8%) DETERGENT (2%) WATER (90-95%)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR RECOMM/APPROVED IN ISOCYANATE
CONTAINING ENVIRONMENTS MAY BE NECESSARY. USE AIR PURIFYING
RSPRTR/POSITIVE PRESSURE SUPPLIED AIR RSPRTR APPROPRIATE FOR
ISOCYANATE CONCENTRATIONS. SEE ORIGINA L MSDS ON FILE FOR FURTHER
INFORMATION.
Ventilation:EXHAUST VENT SUFF TO KEEP AIRBORNE CONC OF HDI AND
POLYISOCYANATE BELOW TLV. EXHAUST AIR MAY NEED TO BE CLEANED.
Other Protective Equipment:COVER AS MUCH SKIN AS POSSIBLE W/APPROPRIATE
CLOTHES. IF SKIN CREAMS USED, KEEP AREA PROTECTED BY ONLY CREAM TO
MINIMUM.
Work Hygienic Practices:USE PRECAUTION TO AVOID SKIN/EYE
CONTACT/BREATHE VAPOR. WASH CONTAM CLOTHING BEFORE REUSE. EYEWASH &
SFTY SHOWER NEEDED.
Supplemental Safety and Health
OVEREXPOSURE TO CHROMIUM SOLVENT HAS BEEN ASSOCIATED W/PERMANENT
BRAIN/NERVOUS SYSTEM DAMAGE. SKIN: DEFATTING, DERMATITIS. SOLVENTS
CAN PENETRATE SKIN & CAUSE SYSTEMIC EFFECTS. INGEST: IRRITATION &
PO SSIBLE CORROSIVE ACTION IN MOUTH, INTEST TRACT. VOMITING
(ASPIRATION OF MAT'L) CAN RESULT IN CHEMICAL PNEUMONITIS.
================== Physical/Chemical Properties ==================
Vapor Density:> AIR
Viscosity:183 MPAS @20C
Evaporation Rate & Reference:SLOWER ETHER (BU AC=1)
Solubility in Water:INSOL/REACTS W/WATER
Appearance and Odor:CLEAR TO PALE YELLOW LIQUID/SOLVENT ODOR
Percent Volatiles by Volume:CA 30
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, AMINES, STRONG BASES, ALCOHOLS, METAL COMPOUNDS, AND SURFACE
ACTIVE MATERIALS.
Stability Condition to Avoid:MOISTURE, HIGH TEMPERATURES, SHOCK FROM
DROPPING.
Hazardous Decomposition Products:BY HIGH HEAT AND FIRE: CARBON DIOXIDE,
CARBON MONOXIDE, OXIDES OF NITROGEN, TRACES OF HCN AND HDI.
Conditions to Avoid Polymerization:MAY OCCUR IF IN CONTACT W/MOISTURE
OR OTHER MATERIALS WHICH REACT W/ISOCYANATES. MAY OCCUR AT
TEMPERATURES OVER 400 F.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORD W/ FEDERAL, STATE & LOCAL
ENVIRONMNTL CNTRL REGS. INCINERATION PREFERRED. IGNITABLE HAZARDOUS
WASTE (PROD RESIDUE/FLAMMABLE SOLVENT VAPOR). DECONTAMINATE CNTNRS
PRIOR TO DISPOSAL. DO N'T HEAT/CUT ON OR NEAR EMPTY CNTNRS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:X4888 RED CHEM-O-SOL
CAGE:78518
CAGE:78518
============= Composition/Information on Ingredients =============
Ingred Name:VENT: IN INGRED SEC BELOW ACCEPTABLE LIMIT, LEL IN INGRED
SEC BELOW STATED LIMIT, AND REMOVE DECOMP PROD WELDING(ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: OR FLAME CUTTING ON SURFACES COATED WITH PRODUCT.
RTECS #:9999999ZZ
Ingred Name:CARCINOGEN: DI-(2-ETHYL HEXYL) PHTHALATE: GROUP 2 (NTP),
GROUP 2B (IARC).
RTECS #:9999999ZZ
Ingred Name:ANTIMONY OXIDE
CAS:1309-64-4
RTECS #:CC5650000
Fraction by Wt: 1.527%
OSHA PEL:0.5 MG/M3 (SB)
ACGIH TLV:0.5 MG/M3 (SB)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:LEAD COMPOUNDS; (LEAD COMPOUND(S) INSOLUBLE)
Fraction by Wt: 1.079%
OSHA PEL:0.05 MG/M3 (PB)
ACGIH TLV:0.15 MG/M3 (PB)
Ingred Name:CHROMIC ACID, LEAD (2+) SALT (1:1); (LEAD CHROMATE (PB; CR
CMPD))
CAS:7758-97-6
RTECS #:GB2975000
Fraction by Wt: 0.215%
OSHA PEL:0.05 MG/M3 (MFR)
ACGIH TLV:0.05 MG/M3
Ingred Name:PATHALIC ACID, BIS(2-ETHYLHEXYL)ESTER; (DI-2-ETHYLHEXYL
PHTHALATE)
CAS:117-81-7
RTECS #:TI0350000
Fraction by Wt: 22.138%
OSHA PEL:10 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL: ANESTHETIC, IRRITATION OF THE
RESPIRATORY TRACT OR ACUTE NERVOUS SYSTEM, DEPRESSION CHARACTERISED
BY HEADACHE, DIZZINESS, STAGGERING GAIT, CONFUSION,
UNCONSCIOUSNESS, OR COMA. SKIN OR EYE: PRIM ARY IRRITANT.
Explanation of Carcinogenicity:ANTIMONY TRIOXIDE:GRP 2B(IARC); LEAD &
LEAD CPDS:GRP 2B(IARC); LEAD CHROMATE: GROUP 1(NTP), GROUP 1(IARC);
(ING 7)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:FUMES: INHAL: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP
WARM & QUIET. NOTIFY PHYSICIAN. SPLASH(EYES): FLUSH IMMEDIATELY
WITH COPIOUS QUANTITIES OF RUNNING WATER FOR AT LEAST 15 MIN. TAKE
TO A PHYS ICIAN FOR A DEFINITIVE MEDICAL TREATMENT. SPLASH(SKIN):
REMOVE WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. INGEST:
GET MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>390F,>199C
Extinguishing Media:USE NFPA CLASS B EXTINGUISHER CARBON DIOXIDE, DRY
CHEMICAL OR FOAM DESIGNED TO EXTING NFPA CLASS I B FLAMM LIQ FIRES.
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. WATER MAY BE
USED TO COOL CLSD CNTNRS TO PVNT PRESS BUILD-UP & POSS
AUTOIGNIT/EXPLO WHEN EXPOSED TO EXTREME HEAT. IF (SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120 F.
Other Precautions:DO NOT TAKE INTERNALLY. AVOID FREE FALL OF LIQUID IN
EXCESS OF A FEW INCHES. DO NOT FLAME CUT, BRAZE, OR WELD WITHOUT US
BUREAU OF MINES APPROVED RESPIRATOR OR APPROPRIATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN OUTDOOR/OPEN AREAS USE NIOSH/MSHA APPROVED
MECH FILTER RSP TO REMOVE SOLID AIR BORNE PARTICLES OF OVERSPRAY
DURING SPRAY APPLICATION. IN RESTRICTED VENT AREAS USE NIOSH/MSHA
APPROVED CHEMICAL-MECH FILTERS DESIGNED TO REMOVE (SUPP DATA)
Ventilation:PROVIDE GEN DILTION/LOC EXHST VENT DURING SPRAY &/OR FUSING
IN VOLUME AND PATTERN TO KEEP TLV OF MOST HAZ ING (ING 5)
Other Protective Equipment:PREVENT PROLONGED SKIN CONTACT WITH
CONTAMINATED CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC: H*2O IS USED, FOG NOZZ PREFERABLE. WEAR NIOSH/MSHA
APPRVD SCBA & FULL PROT EQIP. HAZ DECOMP PROD: OF ANY HEAVY METALS
LISTED IN INGRED SEC. RESP PROT: A COMBINATION OF PARTICULA TES &
GAS & VAP. IN CONFINED AREAS USE NIOSH/MSHA APPRVD AIR LINE TYPE
RESP/HOODS.
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY PRODUCE HAZ FUMES WHEN HEATED TO
DECOMP AS IN WELDING. FUMES MAY CONTAIN CO, AND HCL, AS WELL AS
OXIDES (SUPP DATA)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HYDROGEN SELENIDE
Kit Part:=== Responsible Party ===
780-471-4031
780-471-4031
CAGE:Company Name:MATHESON TRI-GAS, INC.
780-471-4031
CAGE:
============= Composition/Information on Ingredients =============
Ingred Name:HYDROGEN SELENIDE
CAS:7783-07-5
Fraction by Wt: 100.0%
===================== Hazards Identification =====================
Medical Cond Aggravated by Exposure:
======================= First Aid Measures =======================
First Aid: INHALATION: If adverse effects occur, remove to
uncontaminated area. Give artificial respiration if not breathing.
If breathing is difficult, oxygen should be administered by
qualified personnel. Get immediate medical attention. SKIN CONTACT:
If frostbite or freezing occur, immediately flush with plenty of
lukewarm water (105-115 F; 41-46 C). DO NOT USE HOT WATER. If warm
water is not available, gently wrap affected parts in blankets. Get
immediate medical attention. EYE CONTACT: Wash eyes immediately
with large amounts of water or normal saline, occasionally lifting
upper and lower lids, until no evidence of chemical remains. Get
medical attention immediately. INGESTION: If a large amount is
swallowed, get medical attention. NOTE TO PHYSICIAN: For
inhalation, consider oxygen. Consider olive oil, epinephrine
sulfate, local anesthetics, hot and cold compresses.
===================== Fire Fighting Measures =====================
Flash Point:flammable
Extinguishing Media:Let burn unless leak can be stopped immediately.
Large fires: Use regular foam or flood with fine water spray.
Fire Fighting Procedures:Move container from fire area if it can be
done without risk. Cool containers with water spray until well
after the fire is out. Stay away from the ends of tanks. For fires
in cargo or storage area: Cool containers with water from unmanned
hose holder or monitor nozzles until well after fire is out. If
this is impossible then take the following precautions: Keep
unnecessary people away, isolate hazard area and deny entry. Let
the fire burn. Withdraw immediately in case of rising sound from
venting safety device or any discoloration of tanks due to fire.
For tank, rail car or tank truck: Evacuation radius: 800 meters
(1/2 mile).
Unusual Fire/Explosion Hazard:Severe fire hazard. The vapor is heavier
than air. Vapors or gases may ignite at distant ignition sources
and flash back. Vapor/air mixtures are explosive above flash point.
Containers may rupture or explode if exposed to heat.
================== Accidental Release Measures ==================
Spill Release Procedures:Avoid heat, flames, sparks and other sources
of ignition. Stop leak if possible without personal risk. Reduce
vapors with water spray. Keep unnecessary people away, isolate
hazard area and deny entry. Remove sources of ignition. Notify
Local Emergency Planning Committee and State Emergency Response
Commission for release greater than or equal to RQ (U.S. SARA
Section 304). If release occurs in the U.S. and is reportable under
CERCLA Section 103, notify the National Response Center at
(800)424-8802 (USA) or (202)426-2675 (USA).
Neutralizing Agent:
======================Handling and Storage ======================
Other Precautions:
============= Exposure Controls/Personal Protection =============
Respiratory Protection:The following respirators and maximum use
concentrations are drawn from NIOSH and/or OSHA. 0.5 ppm Any
supplied-air respirator. 1 ppm Any supplied-air respirator. Any
self-contained breathing apparatus with a full facepiece. Any
supplied-air respirator with a full facepiece. Escape - Any
air-purifying respirator with a full facepiece and a canister
providing protection against this substance. Only non-oxidizable
sorbents are allowed (not charcoal). Any appropriate escape-type,
self-contained breathing apparatus. For Unknown Concentrations or
Immediately Dangerous to Life or Health - Any supplied-air
respirator with full facepiece and operated in a pressure-demand or
other positive-pressure mode in combination with a separate escape
supply. Any self-contained breathing apparatus with a full
facepiece.
Ventilation:Provide local exhaust or process enclosure ventilation
system. Ventilation equipment should be explosion-resistant if
explosive concentrations of material are present. Ensure compliance
with applicable exposure limits.
Provide an emergency eye wash fountain and quick drench shower in
the immediate work area.
Other Protective Equipment:For the gas: Wear appropriate chemical
resistant clothing. For the liquid: Wear appropriate protective,
cold insulating clothing.
Supplemental Safety and Health
HYDROGEN SELENIDE: HYDROGEN SELENIDE (as Se): 0.05 ppm (0.2 mg/m3)
OSHA TWA 0.05 ppm ACGIH TWA 0.05 ppm (0.2 mg/m3) NIOSH recommended
TWA 10 hour(s)
================== Physical/Chemical Properties ==================
Boiling Pt:-44 F (-42 C)
Melt/Freeze Pt:-83 F (-64 C)
Vapor Pres:7220 mmHg @ 21.1 C
Vapor Density:2.8
Spec Gravity:2.12 @ -42 C
pH:acidic
Evaporation Rate & Reference:Not applicable
Solubility in Water:377% @ 4 C
Appearance and Odor:PHYSICAL STATE:gas COLOR:colorless ODOR:unpleasant
odor
Corrosion Rate:
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:May ignite on exposure to air.
May explode on contact with water.
Stability Condition to Avoid:Avoid heat, flames, sparks and other
sources of ignition. Minimize contact with material. Avoid
inhalation of material or combustion by-products. Keep out of water
supplies and sewers.
Hazardous Decomposition Products:Thermal decomposition products: oxides
of selenium Thermal decomposition products: oxides of selenium
Conditions to Avoid Polymerization:Will not polymerize.
=================== Toxicological Information===================
Toxicological Information:HYDROGEN SELENIDE: TOXICITY DATA: 300 ppb/8
hour(s) inhalation-guinea pig LC50 LOCAL EFFECTS: Irritant:
inhalation, skin, eye ACUTE TOXICITY LEVEL: Highly Toxic:
inhalation MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE: liver
disorders, respiratory disorders
===================== Ecological Information =====================
Ecological:Not available
==================== Disposal Considerations ====================
Waste Disposal Methods:Dispose in accordance with all applicable
regulations. Subject to disposal regulations: U.S. EPA 40 CFR 262.
Hazardous Waste Number(s): D003.
=================== MSDS Transport Information ===================
Transport Information:U.S. DOT 49 CFR 172.101. SHIPPING NAME-UN NUMBER;
HAZARD CLASS; PACKING GROUP; LABEL: Hydrogen selenide,
anhydrous-UN2202; 2.3; Poison gas; Flammable gas
===================== Regulatory Information =====================
SARA Title III Information: SARA SECTION 302 (40CFR355.30): Y
HYDROGEN SELENIDE (as Se): 10LBSTPQ SARA SECTION 304
(40CFR355.40): Y HYDROGEN SELENIDE (as Se): 10LBSRQ SARA SECTION
313 (40CFR372.65): Y HYDROGEN SELENIDE (as Se)
SARA HAZARD CATEGORIES, SARA SECTIONS 311/312 (40CFR370.21):
ACUTE: Y CHRONIC: N FIRE: Y REACTIVE: YSUDDEN RELEASE: Y
Federal Regulatory Information:TSCA INVENTORY STATUS:Y OSHA PROCESS
SAFETY (29CFR1910.119): Y HYDROGEN SELENIDE (as Se): 150LBSTQ
State Regulatory Information: California Proposition 65: N
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TFE PIPE THREAD SEALER
CAGE:GO039
CAGE:5L381
CAGE:GO039
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM OIL
Fraction by Wt: 1-99%
Other REC Limits:AS MIST/FUME
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS PRODUCT IS CONSIDERED MILDLY
IRRITATING TO THE SKIN. SYMPTOMS COULD INCLUDE SKIN REDNESS OR
IRRITATION IF PROLONGED SKIN CONTACT OCCURS. THIS PRODUCT CONTAINS
"TEFLON" WHICH HAS BEEN KNOWN TO PRO DUCE A CONDITION KNOWN AS
POLYMER FUME FEVER IF GOTTEN ONTO TOBACCO PRODUCTS WHILE SMOKING.
DO NOT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:SMOKE WHILE USING THIS MATERIAL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN:WASH W/SOAP & WATER, USING NAIL BRUSH. PAY PARTICULAR
ATTN TO FINGER NAILS & OPEN WOUNDS. EYE:PROD COULD CAUSE SOME MECH
IRRIT IF GOTTEN INTO EYES & RUBBED. FLUSH W/WATER FOR @ LST 15 MIN,
LIFTIN G LIDS. IF IRRIT PERSISTS, CONSULT MD. INGEST:PROD IS NOT
EXPECTED TO CAUSE AN ACUTE RXN & IS RELATIVELY NON-TOX. PROD CNTNS
PETROL OIL, DO NOT INDUCE VOMIT BECAUSE OIL MAY BE ASPIRATED INTO
(SUP DAT)
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>350F,>177C
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. CMPD WILL NOT BURN UNLESS IT IS PRE-HEATED. WATER FOG MAY BE USED
TO COOL CNTNRS BUT DO NOT SPRAY (SUPDAT)
Unusual Fire/Explosion Hazard:DENSE SMOKE AND NOXIOUS OR TOXIC FUMES
MAY BE GENERATED IN A FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:BECAUSE OF THE VISCOUS NATURE OF THIS PRODUCT,
LEAKS ARE NOT EXPECTED. IF SPILLED, SCOOP BACK INTO ORIGINAL
CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM STRONG OXIDIZING
CHEMICALS AND ACIDS.
Other Precautions:DO NOT TRANSFER TO UNMARKED CONTAINERS. KEEP AWAY
FROM CHILDREN. DO NOT EAT OR SMOKE WHILE USING THIS PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NORMALLY NOT REQUIRED.
Ventilation:LOCAL EXHAUST:YES.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER .
Work Hygienic Practices:USE GOOD PRACTICES WHEN USING THIS MATL. AFTER
USE, THORO WASH W/SOAP & WATER, USING NAIL BRUSH.
Supplemental Safety and Health
FIRE FIGHT PROC:DIRECTLY INTO LG CNTNRS OF BURNING LIQS AS FROTHING MAY
OCCUR. HAZ DECOMP PRODS:MAY BE TOX/IRRIT. FIRST AID PROC:LUNGS. USE
GASTRIC LAVAGE & CALL POIS CTL CTR/MD. INHAL:IF USING IN HIG H TEMP
APPLICATNS WHERE THERMAL DECOMP IS LIKELY, USE LOC EXHST TO REMOVE
FUMES. IF DIZZ/IRRIT OCCURS, SEEK FRESH AIR.
================== Physical/Chemical Properties ==================
Spec Gravity:1.2 (H*2O=1)
Evaporation Rate & Reference:0 (BUTYL ACETATE=1)
Solubility in Water:NIL
Appearance and Odor:OFF WHITE LIQUID GRANULAR PASTE WITH A PETROLEUM
LIKE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS SUCH AS HYDROCHLORIC, SULFURIC, NITRIC, ETC.
Stability Condition to Avoid:STRONG OXIDIZING AGENTS AND TEMPERATURES
EXCEEDING 550F.
Hazardous Decomposition Products:THERMAL DECOMP PRODS ARE HIGHLY
DEPENDENT UPON COMBUST CNDTNS. NOXIOUS/TOX FUMES MAY BE GENERATED,
SOME OF WHICH(SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW LOCAL, STATE AND FEDERAL GUIDELINES.
DISPOSE OF IN A RESPONSIBLE MANNER. INCINERATION IS THE PREFERRED
METHOD OF DISPOSAL, ALTHOUGH IT CAN BE LANDFILLED AT AN APPROVED
FACILITY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BOSS 440 COMPOUND
CAGE:58149
CAGE:58149
============= Composition/Information on Ingredients =============
Ingred Name:SILICA GEL; (SILICA, AMORPHOUS)
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 9%
OSHA PEL:6 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:DIRECT CONTACT MAY CAUSE TEMP
DISCOMFORT W/MILD REDNESS SIMILAR TO WINDBURN. SKIN:SINGLE PROLNGD
EXPOS (24-48 HRS) CAUSES NO KNOWN ADVERSE EFT. INHAL:NO IRRIT TO
EYES & RESP PASSAGES. NO INJURY I S LIKELY FROM RELATIVELY SHORT
EXPOS OF< 8 HRS. INGEST:SML AMTS TRANSFERRED TO MOUTH BY FINGERS
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:DURING USE, ETC, SHOULD NOT INJURE. SWALLOWING
LGE AMTS MAY CAUSE DIGESTIVE DISCOMFORT. NO INJURY FROM SILICA
DUSTS SHOULD OCCUR DURING REASONABLE USE. IF USE CREATES RESPIRABLE
PARTICLES SOME RESP SY S INJURY MAY OCCUR. THESE PRODUCTS AS WITH
ANY CHEMS, MAY ENHANCE ALLERGIC CONDITIONS IN CERTAIN PEOPLE.
Medical Cond Aggravated by Exposure:WE DO NOT KNOW OF ANY MEDICAL
CONDITIONS THAT MIGHT BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMEDIATELY . INHAL: REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE OXYGEN/ARTIFICIAL RESPIRATION) . EYES:
IMMEDIATELY FLUSH EYES W/WATER FOR AT LEAST 15 MINUTES. SKIN: WIPE
OFF AND FLUSH WITH WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>200F,>93C
Extinguishing Media:WATER FOG, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE PRODUCT AND USE ABSORBENT MATERIAL TO
TAKE CARE OF ANY OIL-LIKE RESIDUES. WEAR PROT EQUIP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE REASONABLE CARE & CAUTION.
Other Precautions:PRECAUTIONS & EQUIP LISTED ARE FOR ROOM TEMPERATURE
HANDLING. USE AT ELEVATED TEMPERATURES, OR AEROSOL/SPRAY
APPLICATIONS MAY REQUIRE ADDED PRECAUTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NO RESPIRATORY PROTECTION SHOULD BE NEEDED.
Ventilation:LOCAL EXHAUST: NONE SHOULD BE NEEDED. MECHANICAL (GEN):
RECOMMENDED.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASHING AT MEALTIME AND END OF SHIFT IS
ADEQUATE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Vapor Pres:<5 @ 77F
Spec Gravity:1.1
Solubility in Water:<0.1
Appearance and Odor:VERY LITTLE ODOR, PASTE-LIKE, WITH SOME COLOR.
Percent Volatiles by Volume:<5(WT)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL CAN CAUSE REACTION.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:SILICON DIOXIDE, CARBON DIOXIDE, &
TRACES OF INCOMPLETELY BURNED CARBON PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:ALL FEDERAL, STATE AND LOCAL REGULATIONS
CONCERNING HEALTH & POLLUTION SHOULD BE REVIEWED TO DETERMINE
APPROVAL DISPOSAL PROCEDURES.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:KRYLON 3201-3203 EPOXY APPLICANCE PAINT, 32
CAGE:07982
CAGE:07982
============= Composition/Information on Ingredients =============
Ingred Name:FIRST AID PROC:APART DURING IRRIGATION TO INSURE WATER
CONTACT WITH ENTIRE SURFACE OF EYES AND LIDS. CALL MD.
RTECS #:9999999ZZ
Ingred Name:VENT:BE PROVIDED TO KEEP AIR CONTAM CONCEN LEV BELOW
ACCEPTABLE CRITERIA. LOC EXHAUST VENT ENCLOSED SYS DESIGN (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:PROCESS ISOLATION & REMOTE CONTROL IN COMBINATION
W/APPROP USE OF PERSONAL EQUIP AND PRUDENT WORK PRACT. (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:USE W/ADEQUATE VENT. TO AVOID BREATHING VAP/SPRAY
MIST, OPEN WINDOWS/DOORS OR USE OTHER MEANS, SUCH AS (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:AN EXHAUST FAN TO ENSURE FRESH AIR ENTRY DURING
APPLICATION/DRYING. IF YOU EXPERIENCE EYE WATERING, HDCH (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:OR DIZZ, INCREASE FRESH AIR. WEAR NIOSH/MSHA APPRVD
RESP PROT (NIOSH/MSHA TC23C/EQUIVALENT) OR LEAVE THE AREA.
RTECS #:9999999ZZ
Ingred Name:HYGIENE PRAC:MATERIAL FROM EYES, SKIN AND CLOTHING. WASH
THOROUGHLY AFTER HANDLING.
RTECS #:9999999ZZ
Ingred Name:ACETONE (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 35%
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 10-30%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9192
Ingred Name:PROPANE, 2-METHYL-; (ISOBUTANE)
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 10-30%
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 16%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 2.9%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SUPDAT:INTENTIONAL MISUSE BY DELIBERATELY CONCEN/INHAL
CONTENTS MAY LEAD TO ADDICTION (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:AND MAY BE HARMFUL OR FATAL. ING 5: CAN CAUSE LIVER
AND KIDNEY DAMAGE. CAN CAUSE CNS DEPRESSION, HDCH (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:DIZZ, NAUS, VOMIT, UNCON/EVEN ASPHY.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:SKIN/EYE:CAUSES IRRIT.
INGEST:NOT EXPECTED TO BE HARMFUL UNDER NORMAL CNDTN. IF
INGEST:BURNS/IRRIT TO MUCOUS MEMBRANES, ESOPHAGUS OR GI TRACT CAN
RESULT. INHAL:MAY BE HARMFUL. LIQ/VAP MAY CAUSE IRRIT OF NOSE,
THROAT/LUNGS. CAN CAUSE CNS DEPRESS. ING 1:CAN CAUSE CNS DEPRESS,
HDCH, DIZZ, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:NAUS, VOMIT, UNCON/EVEN ASPHY. ING
2:CYANOSIS, RESP DISTRESS, HDCH, DIZZ, DROWSINESS, UNCON/ASPHY. CAN
CAUSE CNS DEPRESS. ING 3:NONE LISTED BY MFR. ING 4:CAN CAUSE
KIDNEY/LIVER DMG, CNS DEPRE SS. HDCH, DIZZ, NAUS, VOMIT,
UNCON/EVENASPHY. REPORTS HAVE ASSOC RPTD/PRLNG OCCUP OVEREXP TO
SOLVENT W/PERM (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:DILUTE BY DRINKING LARGE QUANTITIES OF WATER. IMMED
CONTACT POISON CONTROL CENTER/HOSPITAL EMERG ROOM FOR ANY OTHER
ADDNL TREATMENT DIRECTIONS. INHAL:REMOVE TO FRESH AIR, IF NOT
BRTHG, GIVE ART IFICIAL RESP. PREF MOUTH-TO-MOUTH. SKIN:FLUSH
W/PLENTY OF WATER. REMOVE CONTAM CLTHG. CALL MD IF IRRIT PERSISTS.
EYE:IMMED FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN. EYELIDS
SHOULD BE HELD (ING 9)
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL, FOAM OR CO2.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE BUT SHOULD BE USED TO
KEEP FIRE EXPOSED CONTAINERS COOL. USE NIOSH/MSHA APPROVED SCBA AND
FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:EXTREMELY FLAMM. DO NOT INCINERATE (BURN)
CONTR. AVOID HEAT. KEEP CONTR BELOW 120F. HIGH TEMPS MAY CAUSE
BURSTING. DO NOT PLACE CONTR ON RADIATOR, (SUPPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. SOAK UP WITH
ABSORBENT MATERIAL AND REMOVE TO A CHEMICAL DISPOSAL AREA. PREVENT
ENTRY INTO NATURAL BODIES OF WATER. AVOID SKIN AND EYE CONTACT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE AT TEMP ABOVE 120F.
Other Precautions:FOLLOWING TECHNIQUES MAY NOT NEC ADDRESS ALL ISSUES
PERTAINING TO YOUR OPERATIONS. THEREFORE, IT IS REC THAT YOU
CONSULT WITH EXPERTS OF YOUR CHOICE TO DETERMINE WHETHER OR NOT
YOUR PROGRAMS ARE ADEQU ATE. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE AIR CONTAM CAN EXCEED ACCEPT CRITERIA, USE
NIOSH/MSHA APPROVED RESP PROT EQUIP. RESP SHOULD BE SELECTED BASED
ON FORM/ CONCEN OF CONTAM IN AIR IN ACCORD W/OSHA 29 CFR
1910.134/OTHER APPLIC STAND ARDS/GUIDELINES.
Ventilation:IF AIRBORNE CONTAM ARE GENERATED WHEN MATL IS
HEATED/HANDLED, SUFFICIENT VENT IN VOLUME/AIRFLOW PATTERNS SHOULD
(ING 10)
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:HANDLE IN ACCORD W/GOOD INDUS HYGIENE & SAFETY
PRAC. THESE PRAC INCLUDE AVOIDING UNNECESSARY EXPOS/REMOVAL OF (ING
15)
Supplemental Safety and Health
EXPLOS HAZ:STOVE/IN DIRECT SUNLT/NEAR OTHER HEAT SOURCES. DO NOT
PUNCTURE CONTR. CONTENTS UNDER PRESS WILL DISCHARGE. VAP MAY IGNITE
EXPLOS. SPRAY MIST/VAP EVAP FROM DEPOSITED FILM IS HEAVIER THAN AIR
/MAY SETTLE IN LOW PLACES/TRAVEL OUTWARD TO A SOURCE OF IGNIT/
FLASHBACK. EFTS OF OVEREXP:BRAIN/NERVOUS SYS DMG. (ING 6)
================== Physical/Chemical Properties ==================
Vapor Density:>AIR
Spec Gravity:<WATER
Evaporation Rate & Reference:FASTER THAN BUTYL ACETATE
Solubility in Water:SLIGHT
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURES, OPEN FLAMES, SPARKS,
PILOT LIGHTS.
Hazardous Decomposition Products:COX.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH LOCAL,
STATE/ PROVINCIAL AND FEDERAL REQUIREMENTS. EMPTY CONTAINERS MAY
CONTAIN EXPLOSIVE VAPORS. DO NOT CUT, PUNCTURE OR WELD ON OR
NEARBY. INCINERATION WILL CAUSE CONTAINERS TO BURST VIOLENTLY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:666 GENERAL PURPOSE CLEANER
CAGE:30530
CAGE:30530
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE OXIDE (SUSP HUMAN CARCINOGEN BY ACGIH, IARC, SUSP
CARC BY NTP; OSHA CANCER HAZARD; IARC - GROUP 1) *98-1*
CAS:75-21-8
RTECS #:KX2450000
ACGIH TLV:1.8 MG/CUM (A2)
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:FORMALDEHYDE, FORMALIN (SUSPECTED HUMAN CARCINOGEN BY IARC;
ACGIH; SUSPECTED CARCINOGEN BY NTP; IARC - GROUP 2A) *98-3*
CAS:50-00-0
RTECS #:LP8925000
ACGIH TLV:0.37 MG/CUM IC (2A)
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:LEAD (ANIMAL CARCINOGEN BY ACGIH, IARC - GROUP 2B) *98-3*
CAS:7439-92-1
RTECS #:OF7525000
Other REC Limits:0.15 MG/M3 MSHA
OSHA PEL:0.2 MG/M3 TWA 8HR
ACGIH TLV:0.15 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:EPOXYPROPANE, PROPYLENE OXIDE
CAS:75-56-9
RTECS #:TZ2975000
Other REC Limits:20 PPM
OSHA PEL:240 MG/CUM
ACGIH TLV:48 MG/CUM (A2)
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:SODIUM METASILICATE; SODIUM SILICATE; WATER GLASS; DISODIUM
SALT SILIC ACID *98-3*
CAS:6834-92-0
RTECS #:VV9275000
Fraction by Wt: 25-75%
Ingred Name:SODIUM CARBONATE (SODA ASH, TRONA, CARBONIC ACID, CRYSTOL
CARBONATE, DISODIUM CARBONATE) *98-3*
CAS:497-19-8
RTECS #:VZ4050000
Fraction by Wt: 20-40%
Ingred Name:SODIUM GLUCONATE
CAS:527-07-1
RTECS #:LZ5235000
Fraction by Wt: 0-5%
Ingred Name:ALCOHOLS, C12-C15, ETHOXYLATED PROPOXYLATED *96-3*
CAS:68551-13-3
Fraction by Wt: 0-5%
Ingred Name:POLY (OXY-1,2-ETHANEDIYL),
ALPHA-(4-NONYLPHENYL)-OMEGA-HYDROXY-,BRANCHED (NONOXYNOL-10)
*98-3*
CAS:127087-87-0
Fraction by Wt: 0-5%
Ingred Name:VOLATILE ORGANIC CONTENT: 0-6 %/WT PHOTOCHEMICALLY
REACTIVE AS PER 40 CFR PART 51.100S.
RTECS #:9999999VO
Fraction by Wt: 0-5%
Ingred Name:SODIUM SALT OF POLYCARBOXYLIC ACID
Fraction by Wt: 0-5%
Ingred Name:ACETALDEHYDE (SUSPECT HUMAN CARCINOGEN)
CAS:75-07-0
RTECS #:AB1925000
OSHA PEL:360 MG/CUM
ACGIH TLV:180 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ARSENIC, ARSENICALS (HUMAN & ANIMAL CARCINOGEN BY IARC
GROUP 1; CONFIRMED CARCINOGEN BY NTP & OSHA) *98-2*
CAS:7440-38-2
RTECS #:CG0525000
OSHA PEL:0.5 MG/CUM
ACGIH TLV:0.2 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CHROMIUM, CHROMIUM METAL, CHROME (CARCINOGEN BY NTP; IARC
GROUP 3) *98-3*
CAS:7440-47-3
RTECS #:GB4200000
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:DIETHYLENE ETHER (DIOXANE), (DIETHYLENE DIOXIDE),
1,4-DIOXANE (ANIMAL CARCINOGEN BY IARC GROUP 2B;CARC BY NTP) *98-2*
CAS:123-91-1
RTECS #:JG8225000
Other REC Limits:25 PPM
OSHA PEL:360 MG/CUM
ACGIH TLV:90 MG/CUM (SKIN)
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION/BURNS TO THE
NOSE, THROAT, LUNGS, EYES & RESPIRATORY TRACT. DAMAGE TO MUCOUS
MEMBRANES. EYES: IRRITATION, BLURRED VISION, BURNS, EYE DAMAGE.
SKIN: IRRITATION, BURNS. INGESTION: HARMFUL. MAY CAUSE GI TRACT
BURNS. BREATHING PRODUCT INTO LUNGS BY INGESTION/VOMITING MAY CAUSE
LUNG INJURY. (SEE SUPP)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, SORE THROAT, COUGHING, SHORTNESS OF
BREATH, BURNS, REDNESS, PAIN, BLURRED VISION, BLISTERING, VOMITING,
STOMACH PAIN, HOLES IN THE MOUTH, SORES, DRYING/CRACKING OF SKIN,
ITCHING, SWELLING
Medical Cond Aggravated by Exposure:INDIVIDUALS W/PRE-EXISTING KIDNEY,
LUNG/SKIN DISORDERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED.
SOMEONE SHOULD STAY W/VICTIM. EYES: IMMEDIATELY FLUSH W/PLENTY OF
WATER FOR 15 MINS. SKIN: WASH THOROUGHLY W/SOAP & WATER. INGESTION:
DON'T INDUCE VOMITING. IF SPONTANEOUS VOMITING OCCURS, KEEP HEAD
BELOW HIPS, AVOID BREATHING INTO LUNGS. OBTAIN MEDICAL ATTENTION IN
ALL CASES. FOR INGESTION, CONSIDER ESOPHAGOSCOPY. AVOID GASTRIC
LAVAGE.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, ALCOHOL-RESISTANT FOAM, DRY CHEMICAL/WATER
SPRAY
Fire Fighting Procedures:KEEP STORAGE CONTAINERS COOL W/WATER SPRAY.
USE POSITIVE-PRESSURE, SELF CONTAINED BREATHING APPARATUS &
STRUCTURAL FIREFIGHTERS PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:EMPTY CONTAINERS MAY RETAIN RESIDUE & CAN
BE DANGEROUS.
================== Accidental Release Measures ==================
Spill Release Procedures:SLIPPERY WHEN WET. WEAR APPROPRIATE PROTECTIVE
CLOTHING. STOP LEAK SAFELY W/O RISK. WEAR PROTECTIVE EQUIPMENT.
SHOVEL INTO SEALABLE CONTAINER FOR DISPOSAL. LARGE: ISOLATE HAZARD
AREA. KEEP UNNECESSARY /UNPROTECTED PERSONNEL FROM ENTERING.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED WHEN NOT
IN USE & DURING TRANSPORT. EMPTY PROUCT CONTAINERS MAY RETAIN
PRODUCT RESIDUE & CAN BE DANGEROUS.
Other Precautions:WHEN DISSOLVING ADD WATER CAUTIOUSLY W/STIRRING.
SLIPPER WHEN WET. DON'T BREATHE PARTICULATES. USE IN A WELL
VENTILATED AREA. AVOID CONTACT W/EYES, SKIN, CLOTHING/SHOES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA-APPROVED RESPIRATORY PROTECTIVE
EQUIPMENT WHEN CONCENTRATION EXCEEDS APPLICABLE EXPOSURE LIMITS.
LARGE SPILLS: USE A SCBA & FULL PROTECTIVE EQUIPMENT.
Ventilation:GENERAL VENTILATION TO MAINTAIN CONCENTRATION BELOW
APPLICABLE EXPOSURE LIMITS. LOCAL EXHAUST-CONTROL AIRBORNE LEVELS.
Other Protective Equipment:CHEMICAL RESISTANT FACESHIELD, BOOTS, APRON,
PROTECTIVE CLOTHING, CLEAN WATER FOR FLUSHING EYES & SKIN.
Work Hygienic Practices:USE GOOD PERSONAL HYGIENE. REMOVE/LAUNDER
CONTAMINATED CLOTHING/SHOES/PROTECTIVE EQUIPMENT BEFORE REUSE.
Supplemental Safety and Health
PH: 12.5 IN A 1% SOLUTION IN WATER. HEALTH HAZ CONT'D:
PROLONGED/REPEATED OVEREXPOSURE MAY CAUSE HOLES IN THE NOSE, MOUTH,
EYE CONTACT MAY RESULT IN CONJUNCTIVITIS. CONTACT LENS USE IS NOT
RECOMMENDED .
================== Physical/Chemical Properties ==================
pH:(SUPP)
Solubility in Water:COMPLETE
Appearance and Odor:GRANULAR FREE-FLOWING WHITE POWDER W/PINE/CITRUS
ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, OXIDIZING AGENTS, REDUCING AGENTS, METALS; ALUMIUM, ZINC,
REACTIVE HALOGENS; FLUORINE
Hazardous Decomposition Products:UPON HEATING: HYDROGEN GAS, SODIUM
OXIDES, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS. USEPA WASTE: D002. DOT UN1759 CORROSIVE
SOLIDS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SHER-WOOD WIPING STAIN, S64N5
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:ING 4:INTERNALLY. KEEP OUT OF THE REACH OF CHILDREN.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:VENT. AVOID BRTHG VAP & SPRAY MIST. AVOID CNTCT
W/SKIN & EYES. APPLIC LIMITS FOR NUISANCE DUSTS ARE (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:ACGIH TLV 10 MG/M3 (TOTAL DUST), OSHA PEL 15 MG/M3
(TOTAL DUST), 5 MG/M3 (RESPIRABLE FRACTION).
RTECS #:9999999ZZ
Ingred Name:RESP PROT:BE GENERATED FROM PRODUCT, UNDERLYING PAINT OR
ABRASIVE.
RTECS #:9999999ZZ
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (MINERAL SPIRITS) VP:
2
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 78%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:VOLATILE ORGANIC COMPOUNDS: TOTAL: 5.59 LBS/GAL, LESS
WATER: 5.60 LBS/GAL
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:APPLIANCES & ANY OTHER SOURCES OF IGNIT. CONSULT
NFPA CODE. USE APPRVD BONDING & GROUNDING PROC. KEEP (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:CNTNR CLSD WHEN NOT IN USE. TRANSFER ONLY TO APPRVD
CNTNRS W/COMPLETE & APPROP LABELING. DO NOT TAKE (ING 5)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATION OF EYES, SKIN &
RESPIRATORY SYSTEM. MAY CAUSE NERVOUS SYSTEM DEPRESSION. EXTREME
OVEREXP MAY RESULT IN UNCON & POSSIBLY DEATH. HEADACHE, DIZZINESS,
NAUSEA & LOSS OF COORDINATION ARE I NDICATIONS OF EXCESSIVE
EXPOSURE TO VAPORS/SPRAY MISTS. REDNESS & ITCHING/BURNING SENSATION
MAY (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:INDICATE EYE OR EXCESSIVE SKIN
EXPOSURE. CHRONIC: PROLONGED OVEREXP TO SOLVENT INGREDIENTS IN
PRODUCT MAY CAUSE ADVERSE EFFECTS TO LIVER, URINARY, BLOOD-FORMING,
CARDIOVASCULAR & REPRODUCTIVE SYSTEMS. REPORTS HAVE ASSOCIATED
REPEATED & PROLONGED OVEREXP TO SOLVENTS WITH PERMANENT BRAIN &
NERVOUS SYSTEM DAMAGE.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP
WARM AND QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP AND
WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE RE-USE.
EYES: FLUSH E YES WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. GET MEDICAL ATTENTION. INGESTION: GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:80.0F,26.7C
Lower Limits:0.9%
Upper Limits:19%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
WATER SPRAY MAY BE INEFTIVE. IF WATER IS USED, FOG NOZZ PREF. WATER
MAY BE USED TO COOL CLSD CNTNRS (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPK & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOS TO EXTREME HEAT. APPLICATN TO HOT SURFS (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTENTS ARE FLAMM. KEEP AWAY FROM
HEAT, SPK & OPEN FLAME. DURING USE & UNTIL ALL VAP GONE:KEEP AREA
VENT. DO NOT SMOKE. EXTING ALL FLAMES, (SUPDAT)
Other Precautions:INTENTIONAL MISUSE BY DELIB CONC & INHAL CONTENTS CAN
BE HARMFUL/FATAL. PROD MAY BE MIXED W/OTHER COMPONENTS, INCL
REDUCERS, BEFORE USE. BEFORE OPENING PACKAGE, READ & FOLLOW WARNING
LABELS & MSDS ON ALL COMPONENTS. USE ONLY W/ADEQ (ING 6)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED < APPLIC
LIM BY VENT, WEAR PROPERLY FITTED ORG VAP/PARTICULATE RESP APPRVD
BY NIOSH/ MSHA FOR PROT. WHEN SANDING/ABRADING DRIED FILM, WEAR
DUST/MIST RESP APPRVD BY NIOSH/MSHA FOR DUST WHICH MAY (ING 8)
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPTABLE IF EXPOS TO MATL
MAINTAINED < APPLIC EXPOS LIM. REFER TO OSHA STDS 1910.94,107,108.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC:TO PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN
EXPOSED TO EXTREME HEAT. EXPLO HAZ:REQS SPECIAL PREC. DURING EMER
CNDTNS OVEREXP TO DECOMP PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE
IMMED APPARENT. OBTAIN MED ATTN. HNDLG/STOR PREC:PILOT LIGHTS &
HEATERS. TURN OFF STOVES, ELEC TOOLS & (ING 3)
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:>172F,>78C
Vapor Pres:SEE ING
Vapor Density:HVR/AIR
Spec Gravity:0.81-1.6
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:40-97
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BY FIRE:CARBON DIOXIDE, CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM PROD MAY BE HAZ AS DEFINED UNDER RCRA
40 CFR 261. WASTE MUST BE TESTED FOR IGNIT TO DETERM APPLIC EPA HAZ
WASTE NO. INCIN IN APPRVD FACILITY. DO NOT INCIN CLSD CNTNR.
DISPOSE OF IN ACCORDAN CE W/FED, STATE & LOCAL REGS REGARDING
POLLUTION.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:STAT-LES STRIPPER 457
CAGE:84832
CAGE:84832
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2-(2-BUTOXYETHOXY)-; (DIETHYLENE GLYCOL MONOBUTYL
ETHER)
CAS:112-34-5
RTECS #:KJ9100000
Fraction by Wt: < 20%
Ingred Name:METHANOL; (METHYL ALCOHOL) (SARA III)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: < 15%
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHANOL, 2-AMINO-; (MEA)
CAS:141-43-5
RTECS #:KJ5775000
Fraction by Wt: < 5%
OSHA PEL:3 PPM;6 STEL
ACGIH TLV:3 PPM;6 STEL
Ingred Name:SODIUM HYDROXIDE
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: < 4%
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:CARBON BLACK; (NONYLPHENOXYPOLYETHOXYETHANOL)
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: < 1%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:GLYCINE,
N-(CARBOXYMETHYL)-N'-(2-HYDROXYETHYL)-N,N'-ETHYLENEDI-, TRISODIUM
SALT; (TRISODIUM HEDTA HYDRATE)
CAS:139-89-9
RTECS #:MB9188000
Fraction by Wt: < 1%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRITATION OF EYES AND SKIN MAY
OCCUR WITH OVEREXPOSURE. CONTINUED BREATHING OF VAPORS MAY IRRITATE
RESPIRATORY TRACT CAUSING HEADACHE, NAUSEA AND DIZZINESS. CHRONIC:
UNKNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. RESTORE RESP IF NEC. TREAT
SYMPTOMATICALLY. EYE: FLUSH IMMEDIATELY W/COPIOUS QUANTITIES OF
WATER FOR AT LEAST 15 MIN. CONSULT MD. SKIN:WASH AFFECTED AREAS
W/SOAP & WATER. RE MOVE CONTAM CLTHG. WASH CLTHG BEFORE USE.
CONSULT MD IF IRRIT PERSISTS. INGEST: DRINK 1-2 GLASSES OF WATER TO
DILUTE. DO NOT INDUCE VOMITING. IF SPONTANEOUS VOMIT OCCURS KEEP
HEAD AT OR (SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point:NONCOMBUSTIBLE
Extinguishing Media:EXTINGUISHING MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WATER MAY BE USED TO COOL DOWN UNOPENED CNTNRS
IN VICINTY. FIRE FIGHTERS SHOULD WEAR NIOSH/MSHA APPROVED SCBA AND
FULL PROT EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNIT SOURCES. WEAR APPROP
PERSONAL PROT EQUIP & NIOSH/MSHA APPRVD RESP. CONTAIN SPILL WITH
ABSORBENT MATERIAL AND PUT INTO VAPOR TIGHT CONTAINERS. PREVENT
MATERIAL FROM CONTACTING ANY W ATER SOURCES OR SEWER LEADING TO
SURFACE WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN. STORE
IN CLOSED CONTAINERS IN COMPLIANCE WITH GOOD HOUSEKEEPING
PROCEDURES. PROTECT FROM FREEZING, & EXTREME HEAT.
Other Precautions:STORE AT TEMPERATURES ABOVE 45F.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN OUTDOOR, OPEN AREAS OR WHERE ADEQUATE
VENTILATION EXISTS NONE IS REQUIRED. IN RESTRICTED VENT AREAS USE
NIOSH/MSHA APPROVED ORGANIC VAPOR CARTRIDGE TYPE RESP DESIGNED TO
REMOVE A COMBINATION OF PAR TICLES AND VAPOR.
Ventilation:CONFINED SPACES: MECH VENT IS REQUIRED TO KEEP AIR CONTAM
CONC BELOW CURRENT APPLIC OSHA PERMISSIBLE EXPOS UNITS.
Other Protective Equipment:PREVENT PROLONGED SKIN CONTACT WITH
CONTAMINATED CLOTHING. WATER PROOF BOOTS RECOMMENDED.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING OR USING
WASHROOM FACILITIES.
Supplemental Safety and Health
FIRST AID PROC: BELOW KNEE LEVEL TO PREVENT ASPIRATION INTO LUNGS.
CONSULT PHYSICIAN.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:17@20C/68F
Vapor Density:< 1 WATER
Spec Gravity:0.990
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIQUID, NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ANY MATERIAL THAT REACTS WITH WATER.
Stability Condition to Avoid:PROTECT FROM FREEZING.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
NIIN: 01-418-1198
Product ID: LINE PRE-BURNISH FLOOR CONDITIONER #61-5000-6338-5
Cage: 0F0U5
=======================================================
Contractor Summary
=======================================================
Cage: 0WJ98
Cage: 0F0U5
Country: UK
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: CLEANING COMPOUND,HARD SURFACE-FLOOR
Unit of Issue: BX
Quantitative Expression: 00000000004EA
UI Container Qty: 1
=======================================================
Ingredients
=======================================================
Cas: 7732-18-5
RTECS #: ZC0110000
% Wt: 40-70
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Cas: 111-76-2
RTECS #: KJ8575000
% Wt: 7-13
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 25 PPM SKIN
ACGIH TLV: 25 PPM SKIN
------------------------------
Cas: 68551-14-4
% Wt: 7-13
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
-----------------------------
% Wt: 5-10
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
-----------------------------
Cas: 64-02-8
RTECS #: AH5075000
% Wt: 3-7
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Cas: 1300-72-7
% Wt: 1-5
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES: SEVERE IRRITATION. SKIN: MODERATE IRRITATION, BLOOD
DISORDERS, KIDNEY EFFECTS. INHALATION: UPPER RESPIRATORY IRRITATION. SINGLE
CNS DEPRESSION W/SINGLE OVEREXPOSURE. INGESTION: GI IRRITATION, PO SSIBLE
BLOOD DISORDERS.
Signs And Symptions Of Overexposure: EYES: REDNESS/SWELLING/PAIN/TEARS/CLOUDY
CORNEA/IMPAIRED VISION (POSSIBLY PERMANENTLY IMPAIRED). SKIN:
RED/SWOLEN/ITCHING/DRY. CHRONIC CONTACT MAY CAUSE WEAKNESS/FATIGUE, REDUCED
URINE VOLUME, BLOOD I N URINE, BACK PAIN. INHAL: SORE NOSE/THROAT,
COUGHING/SNEEZING. OVEREXPOSURE: HEADACHE/DIZZINESS/DROWSINESS/*
Medical Cond Aggravated By Exposure: NK *UNCOORDINATED/SLOW REACTION
TIME/SLURRED SPEECH/GIDDINESS/UNCONSCIOUSNESS. INGEST:
PAIN/VOMITING/ABDOMINAL TENDERNESS/NAUSEA/BLOOD IN VOMIT/FECES.
FATIGUE/MUSCULAR WEAKNESS/TREMORS/CONVULSIONS.
First Aid: EYES: IMMED FLUSH W/LARGE AMTS WATER >15 MINUTES. GET MED AID.
SKIN: FLUSH W/LARGE AMTS WATER. IF IRRIT PERSISTS GET MED AID. INHALATION:
GET FRESH AIR. IF NOT BREATHING GIVE ARTIF RESP. IF BREATHING DIFFICULT GET
IMMED MED AID. INGESTION:CALL DR IMMED. ONLY INDUCE VOMITING AT DR
INSTRUCTIONS. NEVER GIVE ANYTHING BY MOUTH TO UNCONSCIOUS PERSON.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: CALL 612-733-1110/612-733-6100 FOR 24 HOUR SPILL
ASSISTANCE. COLLECT SPILLED MATERIAL. CLEAN RESIDUE W/WATER. REFER TO OTHER
SECTIONS OF MSDS FOR INFO ON PHYSICAL/HEALTH HAZARDS, RESP PROTECTION, VENT
ILATION, PERSONAL PROTECTIVE EQUIPMENT.
Waste Disposal Methods: FLUSH SPENT SOLUTIONS/SMALL AMTS <5GL/19L TO WASTE
WATER TREATMENT SYSTSM. REDUCE DISCHARGE RATE IF FOAMING OCCURS. INCINERATE
IN PERMITTED HAZ WASTE INCINERATOR IN PRESCENCE OF COMBUSTIBLE MAT'L. EMP TY
CONTAINERS MAY BE SANITARY LANDFILLED.
Handling And Storage Precautions: KEEP CONTAINER CLOSED WHEN NOT IN USE. KEEP
OUT OF REACH OF CHILDREN.
Other Precautions: KEEP CONTAINER TIGHTLY CLOSED.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NA
Lower Limits: NA
Upper Limits: NA
Extinguishing Media: WATER, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: NONE
Unusual Fire/Explosion Hazard: NONE KNOWN
=======================================================
Control Measures
=======================================================
Respiratory Protection: AVOID INHALATION.
Ventilation: USE IN WELL-VENTILATED AREA.
Other Protective Equipment: NA
Work Hygienic Practices: DON'T INGEST.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 212F,100C
Spec Gravity: 1.04
PH: 9.8
Viscosity: 100CPS
Solubility in Water: COMPLETE
Appearance and Odor: LIQUID, CLEAR, GREEN
Percent Volatiles by Volume: 80.0
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NA
Materials To Avoid: NA
Hazardous Decomposition Products: CARBON MONOXIDE & CARBON DIOXIDE.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 135332
Product ID: LINE PRE-BURNISH FLOOR CONDITIONER #61-5000-6338-5
Review Date: 05/16/1996
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: BX
Container QTY: 1
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: LINE PRE-BURNISH FLOOR CONDITIONER #61-5000-6338-5
Cage: 0F0U5
Company Name: PACEBROOK LTD
Street: 15 GOSDITCH ST
Zipcode: 00000
Country: UK
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: EYES: SEVERE IRRITATION. SKIN: MODERATE IRRITATION,
BLOOD DISORDERS, KIDNEY EFFECTS. INHALATION: UPPER RESPIRATORY IRRITATION.
SINGLE CNS DEPRESSION W/SINGLE OVEREXPOSURE. INGESTION: GI IRRITATION, PO
SSIBLE BLOOD DISORDERS.
EYES: REDNESS/SWELLING/PAIN/TEARS/CLOUDY
CORNEA/IMPAIRED VISION (POSSIBLY PERMANENTLY IMPAIRED). SKIN:
RED/SWOLEN/ITCHING/DRY. CHRONIC CONTACT MAY CAUSE WEAKNESS/FATIGUE, REDUCED
URINE VOLUME, BLOOD IN URINE, BACK PAIN. INHAL: SORE NOSE/THROAT,
COUGHING/SNEEZING. OVEREXPOSURE: HEADACHE/DIZZINESS/ DROWSINESS/*
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PROPANE
Preparer's Name:ROGER L. MAXON
CAGE:0GMK0
CAGE:0GMK0
============= Composition/Information on Ingredients =============
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT MAY CAUSE FROSTBITE (SKIN AND
EYES). INHALATION MAY CAUSE CENTRAL NERVOUS EFFECTS.
Explanation of Carcinogenicity:NONE SPECIFIED BY MANUFACTURER.
Effects of Overexposure:INHALED: DIZZINESS, HEADACHE, DROWSINESS,
NAUSEA, VOMITING, WEAKNESS. SKIN: BLISTERS, PAIN. EYES: PAIN,
REDNESS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALED: REMOVE TO FRESH AIR. GIVE RESPIRATORY SUPPORT AS
NEEDED. SEE DOCTOR. SKIN/EYES: WARM AFFECTED AREA AND GET IMMEDIATE
MEDICAL ATTENTION IF FROSTBITE PRESENT.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-156F,-104C
Autoignition Temp:Autoignition Temp Text:842F
Lower Limits:2.1
Upper Limits:9.5
Extinguishing Media:STOP FLOW OF GAS OR CUT OFF SUPPLY OF OXYGEN
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
BUNKER GEAR. USE WATER TO COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:FIRE EXPOSED CONTAINERS MAY EXPLODE
VIOLENTLY. MAY TRAVEL A CONSIDERBLE DISTANCE TO A SOURCE OF
IGNITION AND FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. SHUT OFF
LEAK IF CAN BE DONE AT NO PERSONAL RISK. VENTILATE AREA.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT TEMPERATURES BELOW 120F IN A
WELL-VENTILATED AREA, FREE OF SOURCES OF IGNITION.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION.
Other Protective Equipment:NONE NORMALLY REQUIRED.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:-44F,-42C
Vapor Pres:197 PSIG
Vapor Density:1.6(AIR=1)
Spec Gravity:0.51
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORLESS GAS, ROTTEN EGG ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER. SOURCES OF
IGNITION AND CONTACT WITH INCOMPATIBLES.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:HEATING OIL
Resp. Party Other MSDS Num.:140012-30
CAGE:3U728
CAGE:3U728
============= Composition/Information on Ingredients =============
Ingred Name:FUEL OIL, NO. 2
CAS:68476-30-2
RTECS #:LS8930000
= Wt:100.
OSHA PEL:NONE
ACGIH TLV:NONE
===================== Hazards Identification =====================
LD50 LC50 Mixture:>2000 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:RESPIRATORY IRRITATION, DIZZINESS,
NAUSEA, LOSS OF CONSCIOUSNESS. PROLONGED, REPEATED SKIN CONTACT MAY
RESULT IN SKIN IRRITATION OR MORE SERIOUS SKIN DIORDERS. NOTE:
THIS PRODUCT COANTAINS POLYCYCLIC AROMATIC HYDROCARBONS, SOME OF
WHICH MAVE BEEN REPORTED TO CAUSE SKIN CANCER IN HUMANS UNDER
CONDITIONS OF POOR PERSONAL HYGIENE, PROLONGED REPEATED CONTACT,
AND EXPOSURE TO SUNLIGHT. TOXIC EFFECTS A RE UNLIKELY TO OCCUR IF
GOOD PERSONAL HYGIENE IS PRACTICED.
Explanation of Carcinogenicity:EXPECTED TO BE CARCINOGENIC IN LIFETIME
MOUSE SKIN PAINTING BIOASSAYS.
Effects of Overexposure:EYE IRRITATION, RESPIRATORY IRRITATION,
HEADACHES, AND NAUSEA.,
Medical Cond Aggravated by Exposure:NO DATA PROVIDED BY MANUFACTURER
======================= First Aid Measures =======================
First Aid:EYE: FLUSH THOROUGHLY WITH WATER. IF IRRITATION OCCURS, CALL
A PHYSICIAN. SKIN: REMOVE CONTAIMINTED CLOTHING. DRY WIPE EXPOSED
SKIN AND CLEANSE YOURSELF WITH WATERLESS HANDCLEANER AND FOLLOW BY
WASHIN G THOROUGHLY WITH SOAP AND WATER. FOR THOSE PROVIDING
ASSISTANCE, AVOID FURTHER CONTACT TO YOUR SELF OR OTHERS. WEAR
REUSE. INHALATI ON: REMOVE FROM FURTHER EXPOSURE. IF RESPIRATORY
IRRITATION, DIZZINESS, NAUSEA, OR UNCONSCIOUSNESS OCCURS, SEEK
IMMEDIATE MEDICAL ASSISTANCE.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>51.7C, 125.F
Lower Limits:0.6
Upper Limits:7.0
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:FOR FIRES IN ENCLOSED AREAS, FIRE FIGHTERS
MUST USE SELF-CONTAINED BREATHING APPARATUS. USE WATER TO KEEP FIRE
EXPOSED CONTAINERS COOL. IF A LEAK OR SPILL HAS NOT IGNITED, USE
WATER SPRAY TO DISPERSE VAPORS AND TO PROTECT PERSONNEL ATTEMPTING
TO STOP LEAK. WATER SPRAY MAY BE USED TO FLUSH SPILLS AWAY FROM
EXPOSURES.
Unusual Fire/Explosion Hazard:MATERIAL IS COMBUSTIBLE. PREVENT RUNOFF
FROM FIRE CONTROL OR DILUTION FROM ENTERING STREAMS, SEWERS, OR
DRINKING WATER SUPPLY.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB ON FIRE RETARDANT TREATED SAWDUST,
DIATOMACEOUS EARTH, ETC. SHOVEL UP AND DISPOSE OF AT AN APPROPRIATE
WASTE DISPOSAL FACILITY IN ACCORDANCE WITH CURRENT APPLICABLE LAWS
AND REGULATIONS, AND PR ODUCT CHARACTERISTICS AT TIME OF DISPOSAL.
PREVENT SPILLS FROM ENTERING STORM SEWERS OR DRAINS AND CONTACT
WITH SOIL.
Neutralizing Agent:NO DATA PROVIDED BY MANUFACTURER
======================Handling and Storage ======================
Handling and Storage Precautions:HARMFUL IN CONTACT WITH OR IF ABSORBED
THROUGH THE SKIN. AVOID INHALATION OF VAPORS OR MIST. STORE IN A
COOL AREA. AVOID SPARKING CONDITIONS. GROUND AND BOND ALL TRANSFER
EQUIPMENT.
Other Precautions:ENSURE THAT THERE ARE NO IGNITION SOURCES IN THE AREA
IMMEDIATELY SURROUNDING FILLING AND VENTING OPERATIONS. PORTABLE
CONTAINERS APPROVED FOR STORING FUEL MUST BE PLACE ON THE GROUND
AND THE NOZZLE M UST STAY IN CONTACT WITH THE CONTAINER WHEN
FILLING TO PREVENT BUILD UP AND DISCHARGE OF STATIC ELEC TRICITY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL REQUIRMENTS UNDER ORDINARY CONDITIONS
OF USE AND WITH ADEQUATE VENTILATION.
Ventilation:USE IN WELL VENTILATED AREA. VENTILATION DESIRABLE AND
EQUIPMENT SHOULD BE EXPLOSION PROOF.
Other Protective Equipment:IF CONTACT IS LIKELY OIL IMPERVIOUS CLOTHING
MUST BE WORN.
Work Hygienic Practices:GOOD PERSONAL HYGIENE PRACTICES SHOULD ALWAYS
BE FOLLOWED.
Supplemental Safety and Health
NOTE TO PHYSICIAN: MATERIAL IF INGESTED MAY BE ASPIRATED INTO THE LUNGS
AND CAN CAUSE CHEMICAL PNEUMONITIS. TREAT APPROPRIATELY.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:>176.7C, 350.F
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:0.5
Vapor Density:>2.0
Viscosity:<1.9 @ 40 C
Evaporation Rate & Reference:NE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:RED LIQUID, HYDROCARBON ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HALOGENS, STRONG ACIDS, ALKALIES, AND OXIDIZERS.
Stability Condition to Avoid:HEAT, SPARKS, FLAME AND BUILD UP OF STATIC
ELECTRICITY.
Hazardous Decomposition Products:CARBON MONOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:ORAL TOXICITY (RATS): PRACTICALLY NON-TOXIC
(LD50: GREATER THAN 2000 MG/KG). DERMAL TOXICITY (RABBITS):
PRACTICALLY NON-TOXIC (LD50: GREATER THAN 2000 MG/KG). INHALATION
TOXICITY (RATS): PRACTICALLY N ON-TOXIC (LC50: > 5 MG/L). EYE
IRRITATION (RABBITS): PRACTICALLY NON-IRRITATING (DRAIZE SCORE: >6
BUT LESS THAN 15). SKIN IRRITATION (RABBITS): PRACTICALLY
NON-IRRITATING. (PRIMARY IRRITATION INDEX: > 0.5 BUT < 3).
REPEATED DERMAL APPLICATION TO RATS FOR 13 WEEKS RESULTED IN
EFFECTS WHICH INCLUDED INCREASED MORTALITY AND DECREASED BODY AND
THYMUS WEIGHTS. SEVERE SKIN IRRITATION ALSO OBSERVED.
===================== Ecological Information =====================
Ecological:ENVIRONMENTAL FATE AND EFFECTS: NOT ESTABLISHED.
==================== Disposal Considerations ====================
Waste Disposal Methods:PRODUCT IS SUITABLE FOR BURNING FOR FUEL VALUE
IN COMPLIANCE WITH APPLICABLE LAWS AND REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:USDOT: SHIPPING NAME: DIESEL FUEL. HAZARD CLASS &
DIV: COMBUSTIBLE LIQUID. ID NUMBER: NA1993. ERG NUMBER: 128.
PACKING GROUP: III. STCC: NE. DANGEROUS WHEN WET: NO. POISON: NO.
LABEL(S): NA. PLACARD: COMBUSTIBLE. PRODUCT RQ: NA. IN ACCORDANCE
WITH 49 CFR 173.150(F)(2), NON-BULK QUANTITIES OF THIS MATERIAL
(<119 GALLONS) MAY BE SHIPPED AS NON-REGULATED FOR US DOMESTIC
SHIPMENTS. IMO: HAZARD CLASS: 3.3 UN NUMBER: 1202. PACKING GROUP:
PG III. SHIPPING NAME: GAS OIL.LABEL(S): FLAMMABLE LIQUID. IATA:
HAZARD CLASS: 3. ID/UN NUMBER: 1202. PACKING ROUP: PG III. SHIPPING
NAME: GAS OIL. SUBSIDIARY RISK: NA. LABEL(S): FLAMMABLE.
===================== Regulatory Information =====================
SARA Title III Information:US SEUPERFUND AMENDMENTS AND REAUTHORIZATION
ACT (SARA) TITLE III: THIS PRODUCT CONTAINS NO "EXTREMELY HAZARDOUS
SUBSTANCES:. SARA (311/312) REPORTABLE HAZRD CATEGORIES: FIRE,
CHRONIC. THIS PRODUCT CO NTAINS NO CHEMICALS REPORTABLE UNDER SARA
(313) TOXIC RELEASE PROGRAM.
Federal Regulatory Information:ALL COMPONENTS COMPLY WITH TSCA AND
EINECS/ELINCS.
State Regulatory Information:THE FOLLOWING PRODUCT INGREDIENTS ARE
CITED ON THE LISTS BELOW: FUEL OIL NO. 2 (CAS# 68476-30-2), LA RTK.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:V47-008 VITA OMEGA OPAQUES
CAGE:67251
CAGE:67251
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM OXIDE, BAUXITE, ALUMINA, DIALUMINUM TRIOXIDE
*97-4*
CAS:1344-28-1
RTECS #:BD1200000
OSHA PEL:15 MG/CUM TOTAL DUST
ACGIH TLV:10 MG/CUM TOTAL DUST
Ingred Name:BARIUM *97-4*
CAS:7440-39-3
RTECS #:CQ8370000
OSHA PEL:0.5 MG/CUM
ACGIH TLV:0.5 MG/CUM
Ingred Name:BORON OXIDE, TRIOXIDE
CAS:1303-86-2
RTECS #:ED7900000
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM
Ingred Name:CALCIUM OXIDE; LIME
CAS:1305-78-8
RTECS #:EW3100000
OSHA PEL:5 MG/CUM
ACGIH TLV:2 MG/CUM
Ingred Name:MAGNESIUM OXIDE, MAGNESIA
CAS:1309-48-4
RTECS #:OM3850000
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM
Ingred Name:POTASSIUM DIOXIDE
CAS:12030-88-5
RTECS #:TT6053000
Ingred Name:AMORPHOUS SILICA GEL, SILICON DIOXIDE *97-4*
CAS:7631-86-9
Ingred Name:SODIUM OXIDE
CAS:1313-59-3
Ingred Name:TIN *97-4*
CAS:7440-31-5
RTECS #:XP7320000
OSHA PEL:2 MG/CUM
ACGIH TLV:2.0 MG/CUM
Ingred Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
CARCINOGEN, IARC GROUP 3)*97-4*
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP AS SOLID WASTE. AVOID BREATHING DUST.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING CERAMIC DUST.
Other Precautions:AVOID LICKING CERAMIC APPLICATION BRUSH.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NUISANCE DUST MASK RECOMMENDED WHILE GRINDING
FIRED CERAMIC.
Ventilation:MECHANICAL EXHAUST RECOMMENDED.
Other Protective Equipment:NOT REQUIRED
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:1760F
Evaporation Rate & Reference:NONE
Solubility in Water:INSOLUBLE
Appearance and Odor:PASTEL COLOR PORCELAINS W/NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONCENTRATED HYDROFLUORIC ACID
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AS SOLID WASTE IN ACCORDANCE W/LOCAL,
STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TORCOAT LIQUID ACCELAGOLD
CAGE:0BYN5
CAGE:6X798
CAGE:0BYN5
============= Composition/Information on Ingredients =============
Ingred Name:CHROMIC ACID (SARA 313) (CERCLA RQ 10)
CAS:1333-82-0
RTECS #:GB6650000
Fraction by Wt: <5.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.05 MG/M3
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM SILICO FLUORIDE
CAS:16893-85-9
RTECS #:VV8410000
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM FERRICYANIDE
CAS:13746-66-2
RTECS #:LJ8225000
Other REC Limits:NONE RECOMMENDED
Ingred Name:HEXAVALENT CHROMIUM COMPOUNDS
Fraction by Wt: 0.5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYE: IRRIT, CONJUNCTIVITIS, CHEMICAL
BURNS, TISSUE DAMAGE, BLINDNESS. SKIN: IRRIT, CHEMICAL BURNS,
ULCERATION, SENSITIZATION. INHAL: ULCERATION, PERFORATION NASAL
SEPTUM, IRRIT, RESP DAMAGE. SYMPTOMS ARE ASTHMA-LIKE. LUNG CANCER.
INGEST: GI IRRIT, HARMFUL, TOXIC EFFECTS MAY BE DELAYED.
Explanation of Carcinogenicity:HEXAVALENT CHROMIUM COMPOUNDS IS LISTED
BY IARC GROUP 1, NTP GROUP A.
Medical Cond Aggravated by Exposure:SYSTEMTIC POISONING AFFECTING
LIVER, KIDNEY, GI TRACT. REPEATED OVEREXPOSURE MAY AGGRAVATED
PRE-EXISTING DISFUNCTION OF THESE SYSTEMS.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/WATER FOR 5 MIN, THEN W/NORMAL SALINE 30-60 MIN
LIFTING LIDS. SKIN: FLUSH W/WATER, THEN WASH W/SOAP & WATER, RINSE
THOROUGHLY. INHAL: GET FRESH AIR. OXYGEN IF NEEDED. INGEST: INDUCE
VOMIT BY SYRUP OF IPECAC OR FINGER AT BACK OF THROAT. REPEAT UNTIL
VOMIT IS CLEAR. DRINK MORE WATER/MUCILAGINOUS DRINKS. GET MED AID
IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:USE SCBA & FULL PROTECTIVE GEAR. WATER RUN-OFF
MAY CONTAIN HEXAVALENT CHROMIUM, SHOULD NOT BE ALLOWED TO ENTER
WATER WAYS.
Unusual Fire/Explosion Hazard:MAY INCREASE FIRE INTENSITY W/CONTACT
W/COMBUSTIBLES. COOL EXPOSED CONTAINERS CAUTIOUSLY W/WATER SPRAY.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROTECIVE EQUIPMENT. STOP LEAK. VENT AREA.
PUMP TO DISPOSAL DRUM. ABSORB REMAINING MATERIAL ON INERT INORGANIC
ABSORBENT & PUT IN DISPOSAL DRUM. WASH W/WATER & COLLECT WASHINGS &
PUT IN DRUM. REMO VE ALL CHROMIUM. KEEP FROM SEWER & WATER WAYS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP DRY PROTECTED. CAREFUL WHEN
MIXING. AVOID SPLASHING. USE APPROPRIATE SAFETY PROTECTION. ADD TO
IN USE TANK CAREFULLY
Other Precautions:REPAIR & MAINTANANCE CONTAM EQUIPMENT: RELIEVE
PRESSURE. COVER OPENINGS TO AVOID SPURTING. FLUSH EXTERIOR/INTERIOR
W/WATER & COLLECT FLUSHINGS FOR DISPOSAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR MIST, NIOSH RESPIRATOR FOR TOXIC DUST/MIST
ADVISED. IF RESPIRATORS ARE USED, FORMAL TRAINING/SCREENING MUST BE
INITIATED.
Ventilation:SUFFICIENT MECHANICAL TO KEEP VAPOR CONCENTRATIONS BELOW
TLV.
Other Protective Equipment:BOOTS/APRON MADE OF MATERIAL RESITANT TO
CHROMIUM ACID (VITON/PVC).
Work Hygienic Practices:WASH W/SOAP & WATER BEFORE EATING/SMOKING.
REMOVE CONTAM CLOTHES, WASH SEPARATELY BEFORE REUSE. DISCARD CONTAM
SHOES.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres: 25 MM HG
Vapor Density:<1 AIR=1
Spec Gravity:1.00
pH:2.0
Evaporation Rate & Reference:<1.0 BUAC=1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR YELLOW SOLUTION, ACID ODOR.
Percent Volatiles by Volume: 98.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, STRONG ALKALIES, REDUCING COMPOUNDS, FLAMMABLE OR
COMBUSTIBLE MATERIAL.
Stability Condition to Avoid:STORE AWAY FORM STRONG ACIDS OR BASES,
REDUCING COMPOUNDS FLAMMABLE OR COMBUSTIBLE MATERIAL.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:TRANSFER TO RECLAIMING CENTER FOR REUSE IF
POSSIBLE. TRANSFER TO LICENSED HAZARDOUS WASTE TREATMENT/DISPOSAL
SITE FOR DISPOSITION UNDER FEDERAL, STATE, LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HALON 1301 AND GLC-13B1
Resp. Party Other MSDS Num.:GLCC PRODUCT CODE: 045, 038
CAGE:06284
CAGE:06284
============= Composition/Information on Ingredients =============
Ingred Name:BROMOTRIFLUOROMETHANE
CAS:75-63-8
RTECS #:PA5425000
Other REC Limits:50000 PPM(NIOSH-LDH)
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
LD50 LC50 Mixture:RAT LC50/4H > 800,000 PPM
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HALON 1301 AND GLC-13B1 HAS ANESTHETIC
AND CARDIAC EFFECTS IN HUMANS AT CONCENTRATIONS ABOVE 10% BY
VOLUME, CONCENTRATIONS BELOW 10% ARE CONSIDERED SAFE FOR 0-5 MINUTE
EXPOSURES.
Explanation of Carcinogenicity:NOT PROVIDED BY MANUFACTURER.
Effects of Overexposure:THE ANESTHETIC EFFECT OF HALON 1301 AND
GLC-13B1 AT LEVELS BELOW 10% IS SIMILAR TO A FEELING OF MILD
INTOXICATION. ANESTHETIC EFFECTS END RAPIDLY AFTER EXPOSURE IS
TERMINATED. PROLONGED EXPOSURE TO CO NCENTRATIONS ABOVE 10%,
(15-20%) MAY LEAD TO UNCONSCIOUSNESS AND POSSIBLY DEATH.
Medical Cond Aggravated by Exposure:CARDIAC CONDITIONS MAY BE
AGGRAVATED BY OVEREXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE PERSON TO FRESH AIR; IF NOT BREATHING,
GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, GIVE
OXYGEN. GET MEDICAL ATTENTION. SKIN: FLUSH WITH WATER. GET MEDICAL
ATTENTION IF FROSTBITE OCCURS. EYES: FLUSH WITH WATER, GET
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:HALON 1301 IS A FIRE EXTINGUISHING AGENT. USE
WATER SPRAY TO COOL CYLINDERS INVOLVED IN FIRES. USE MEDIA
SUITABLE FOR FLAMMABLE MATERIALS IN THE AREA.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:PREDOMINANT DECOMPOSITION PRODUCTS ARE
HYDROGEN FLUORIDE & HYDROGEN BROMIDE IN FIRE SITUATIONS. THE
PRODUCTS ARE IRRITATING & POTENTIALLY TOXIC IF FIRE EXTINGUISHMENT
IS DELAYED. ABOVE 1000F, HALON 13 01 & GLC-13B1 MAY RELEASE
HYDROGEN FLUORIDE, HYDROGEN FLUORIDE, HYDROGEN BROMIDE, CARBONYL
FLUORIDE & CARBONYL BROMIDE
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ARES. WEAR SELF-CONTAINED BREATHING
APPARATUS, VENTILATE ENCLOSED AREAS IN CASE OF DISCHARGE.
Neutralizing Agent:NO DATA PROVIDED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT CYLINDERS FROM PHYSICAL
DAMAGE. STORAGE TEMPERATURE SHOULD NOT EXCEED 125F. CYLINDERS
SHOULD BE SECURED FOR STORAGE WITH VALVE PROTECTION CAP IN PLACE.
Other Precautions:NO DATA PROVIDED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH APPROVED, SELF-CONTAINED BREATHING
APPARATUS AT CONCENTRATIONS GREATER THAN 10,000 PPM AS RECOMMENDED
BY NIOSH. CONSULT ANSI STANDARD AND OSHA REGULATIONS CONCERNING THE
USE OF RESPIRATORYEQUIPMENT. AVOID PROLONGED EXPOSURE TO
EXCESSIVE CONCENTRATIONS.
Ventilation:LOCAL EXHAUST: MATERIAL TRANSFER AND HANDLING SHOULD BE
CONDUCTED WITH AN EXHAUST SYSTEM. MECHANICAL: ALL INDOOR AREAS
SHOULD BE WELL VENTILATED.
Other Protective Equipment:NONE
Work Hygienic Practices:DETERMINE THAT PIPING IS EMPTY BEFORE DOING
MAINTENANCE WORK. PERIODICALLY CHECK CYLINDERS TO ENSURE VALVES ARE
NOT LEAKING.
Supplemental Safety and Health
AVOID EXPOSURE TO THE PRODUCT & DECOMPOSITION PRODUCTS WHEN WEARING
CONTACT LENSES; CLOUDING OF LENSES MAY OCCUR.
================== Physical/Chemical Properties ==================
HCC:G3
Boiling Pt:=-57.6C, -72.F
Melt/Freeze Pt:=-167.6C, -270.F
Decomp Temp:Decomp Text:NOT PROVIDED
Vapor Pres:6200 (MMHG) AT 0 DEG C
Vapor Density:5.1 AIR=1
Spec Gravity:1.57 @ 20 DEG C (WATER=1)
pH:NOT PROVIDED
Viscosity:NOT PROVIDED
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:0.03% BY WEIGHT
Appearance and Odor:ODORLESS, COLORLESS GAS
Percent Volatiles by Volume:NOT PROVIDED
Corrosion Rate:NOT PROVIDED
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACTIVE METALS, FIRES OF METAL HYDRIDES, AND MATERIAL CONTAINING OWN
OXYGEN. PRODUCT WILL NOT EXTINGUISH FIRES OF THESE MATERIALS.
PRODUCT MAY DEGRADE CERTAIN POLYMERIC MATERIALS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:IN THE PRESENCE OF FLAMES OR HOT
SURFACES: HYDROGEN FLUORIDE, HYDROGEN BROMIDE, BROMINE, CARBONYL
FLUORIDE, AND CARBONYL BROMIDE. SMOKING CAN CAUSE FORMATION OF
THESE CHEMICALS AND MUST BE AVOIDED.
Conditions to Avoid Polymerization:WILL NOT OCCUR
=================== Toxicological Information===================
Toxicological Information:APPROXIMATE LETHAL CONCENTRATION OF HALON
1301 & GLC-13B1 TO THE RAT IS GREATER THAN 800,000 PPM FOR 15
MINUTES. THE ACUTE INHALATION LC50 WITH RATS IS GREATER THAN
800,000 PPM FOR 4 HOURS. THE COMPOU ND IS REPORTED TO BE
NON-MUTAGENIC IN THE AMES TEST. HALON 1301 & GLC-13B1 IS CLASSIFIED
AS GROUP 6 (LEAST TOXIC) IN THE UNDERWRITERS LABORATORIES
CLASSIFICATION OF COMPARATIVE LIFE HAZARDS OF FIRE EX TINGUISHING
AGENTS. SMOKING IN AREAS WHERE THIS CHEMICAL IS RELEASED CAN CAUSE
FORMATION OF TOXIC & IRRITATING HALOGENS & HALOGEN ACIDS WHICH CAN
BE INHALED WITH THE SMOKE.
===================== Ecological Information =====================
Ecological:NO DATA PROVIDED BY MANUFACTURER
==================== Disposal Considerations ====================
Waste Disposal Methods:RETURN CYLINDERS TO GREAT LAKES CHEMICAL
CORPORATION, EL DORADO, ARKANSAS.
=================== MSDS Transport Information ===================
Transport Information:DOT: BROMOTRIFLUOROMETHANE, NONFLAMMABLE GAS,
UN1009. IMDG: BROMOTRIFLUOROMETHANE, NONFLAMMABLE COMPRESSED GAS,
2-GASES, UN1009. IATA: BROMOTRIFLUOROMETHANE, 2, UN1009, PACKING
UINSTRUCTION 200, MAXIM UM NET QUANTITY FOR PASSENGER AIRCRAFT 75
KG; MAXIMUM NET QUANTITY FOR CARGO AIRCRAFT 150 KG. EXPORT:
BROMOTRIFLUOROMETHANE, NONFLAMMABLE GAS, UN1009, IMO CLASS 2.2.
===================== Regulatory Information =====================
SARA Title III Information:BROMOTRIFLUOROMETHANE: THIS CHEMICAL IS
SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF TITLE III
OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 AND 40
CFR PART 372.
Federal Regulatory Information:NO DATA PROVIDED BY MANUFACTURER.
State Regulatory Information:NO DATA PROVIDED BY MANUFACTURER.
======================= Other Information =======================
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:CLARKE BLEND 19, 2223799
CAGE:DO048
CAGE:DO048
CAGE:0AHD5
============= Composition/Information on Ingredients =============
Ingred Name:ING 7:& SAFE HANDLING & EXPOSURE INFORMATION .
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:ADMIN OXYGEN. IF BRTHG HAS STOPPED GIVE ARTF
RESP. KEEP PERSON WARM, QUIET & GET MEDICAL ATTENTION.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:BEEN COMPLETED. STOP SPILL AT SOURCE, DIKE AREA
OF SPILL TO PVNT SPREADING, PUMP LIQ TO SALVAGE TANK.(ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:REMAINING LIQ MAY BE TAKEN UP ON SAND, CLAY, EARTH,
FLOOR ABSORB/OTHER ABSORB MATL & SHOVELED INTO (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:CNTNRS. PVNT RUN-OFF TO SEWERS, STREAMS/OTHER BODIES
OF WATER. IF RUN-OFF OCCURS, NOTIFY PROPER AUTHS AS (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:REQUIRED, THAT A SPILL HAS OCCURED.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:CNDTNS (SEE YOUR SAFETY EQUIP SUPPLIER).
ENGINEERING/ADMIN CONTROLS SHOULD BE IMPLEMENTED TO REDUCE
EXPOSURE.
RTECS #:9999999ZZ
Ingred Name:ISOPROPYL ALCOHOL; (ISOPROPANOL) (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 10-15%
OSHA PEL:400 PPM;500 PPM STEL
ACGIH TLV:400 PPM;500 PPM STEL
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 69%
OSHA PEL:200 PPM;150 PPM STEL
ACGIH TLV:50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETIC ACID, ISOBUTYL ESTER; (ISOBUTYL ACETATE) (SARA III)
CAS:110-19-0
RTECS #:AI4025000
Fraction by Wt: 5-10%
OSHA PEL:150 PPM
ACGIH TLV:150 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETIC ACID, ISOPROPYL ESTER; (ISOPROPYL ACETATE)
CAS:108-21-4
RTECS #:AI4930000
Fraction by Wt: 5-10%
OSHA PEL:250 PPM;310 PPM STEL
ACGIH TLV:250 PPM;310 PPM STEL
Ingred Name:ACETONE (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 4%
OSHA PEL:1000 PPM
ACGIH TLV:750 PPM;1000 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SUPDAT:DISTANT FROM MATERIAL HANDLING POINT.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP:CHEM REPRO HAZS. SEEK CONSULTATION FROM
APPROP HLTH PROFESSIONALS CONCERNING LATEST HAZ LIST INFO(ING 8)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES:CAUSES IRRIT, REDNESS,
TEARING. SKIN:PRLNG/RPTD CONT CAN CAUSE MOD IRRIT, DEFAT, DERM.
INHAL:EXCESSIVE INHAL OF VAPS CAN CAUSE NASAL & RESP IRRIT, CNS
EFTS INCL DIZZ, WEAK, FATG, NAUS, HDCH & POSS UNCON & EVEN DEATH.
INGEST:CAN CAUSE GI IRRIT, NAUS, VOMIT & DIARR. CHRONIC:OVEREXP TO
THIS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:MATL (OR ITS COMPONENTS) HAS
APPARENTLY BEEN FOUND TO CAUSE FOLLOWING EFTS IN LAB ANIMALS:LIVER
ABNORMS, KIDNEY DMG, EYE DMG, LUNG DMG, SPLEEN DMG. OVEREXTP TO
THIS MATL (OR ITS COMPONENTS) H AS BEEN SUGGESTED AS CAUSE OF
FOLLOWINGEFTS IN HUMANS:LIVER ABNORMS. NOTE:TOLUENE APPEARS ON NAVY
LIST OF OCCUP (ING 7)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN:THORO WASH EXPOS AREA W/SOAP & WATER. REMOVE & LAUNDER
CONTAM CLTHG BEFORE RE-USE. EYES:FLUSH W/LG AMTS OF WATER FOR AT
LST 15 MINS, LIFTING UPPER & LOWER LIDS OCCAS, GET MED ATTN.
INGEST:DO NOT INDUCE VOMIT, KEEP PERS WARM, QUIET & GET MED ATTN.
ASPIR OF MATL INTO LUNGS DUE TO VOMIT CAN CAUSE CHEM PNEUM WHICH
CAN BE FATAL. INHAL:REMOVE INDIVIDUAL TO FRESH AIR. IF BRTHG IS
DFCLT, (ING 9)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:<20F,<-7C
Lower Limits:1.2%
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NEVER USE WELDING/CUTTING TORCH ON/NEAR
DRUM (EVEN EMPTY) BECAUSE PROD (EVEN JUST RESIDUE) CAN IGNITE
EXPLOSIVELY. ALL 5 GAL PAILS & LGR METAL CNTNRS (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:SM SPILL:ABSORB LIQ ON PAPER, VERMICULITE,
FLOOR ABSORB/OTHER ABSORB MATL. LG SPILL:ELIM ALL IGNIT SOURCES,
(FLARES, FLAMES INCL PILOT LIGHTS, ELEC SPKS). PERS NOT WEARING
PROT EQUIP SHOULD BE EXCLUDE D FROM AREA OF SPILL UNTIL CLEAN-UP
HAS(ING 10)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTIED. SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES (VAPOR,
LIQUID &/OR SOLID), ALL HAZARD PRECAUTIONS GIVEN IN THIS MSDS MUST
BE OBSERVED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF WORKPLACE EXPOS LIM(S) OF PROD/ANY COMPONENT
IS EXCEEDED, NIOSH/MSHA APPRVD AIR SUPPLIED RESP IS ADVISED IN
ABSENCE OF PROPER ENVIRON CONTROL. OSHA REGS ALSO PERMIT OTHER
NIOSH/MSHA APPRVD RESPS (N EG PRESS TYPE) UNDER SPECIFIED (ING 14)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL &/OR LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING & BOOTS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ:INCL TANK CARS & TRUCKS SHOULD BE GROUNDED &/OR BONDED WHEN
MATL IS TRANSFERRED. MATL IS HIGH VOLAT & READILY GIVES OFF VAPS
WHICH MAY TRAVEL ALONG GROUND/BE MOVED BY VENT & IGNITED BY PILOT
LIGHTS, OTHER FLAMES, SPKS, HEATERS, SMOKING, ELEC MOTORS, STATIC
DISCHARGE/OTHER IGNIT SOURCES AT LOCATIONS (ING 6)
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:133F,56C
Vapor Pres:181.7 @20C
Vapor Density:>1
Spec Gravity:<1
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W ALL LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:2076 PH 10.00 BUFFER SOL
CAGE:6U393
CAGE:MCBEN
CAGE:6U393
============= Composition/Information on Ingredients =============
Ingred Name:BORIC ACID
CAS:10043-35-3
RTECS #:ED4550000
Fraction by Wt: 0-3%
OSHA PEL:10 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:POTASSIUM CHLORIDE
CAS:7447-40-7
RTECS #:TS8050000
Fraction by Wt: 0-3%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: 94-100%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRITATION TO EYES AND SKIN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING HAS STOPPED
GIVE ARTIFICIAL RESPIRATION. EYES: FLUSH EYES WITH WATER FOR AT
LEAST 15 MINUTES. SEEK MEDICAL ATTENTION IMMEDIATELY. SKIN: FLUSH
SKIN WITH WA TER FOR 15 MINUTES. SEEK MEDICAL ATTENTION IF ANY
IRRITATION PERSISTS. INGESTION: DO NOT INDUCE VOMITING. DILUTE BY
GIVING LARGE AMOUNTS OF WATER. SEEK MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:FOAM, DRY CHEMICAL, ALCOHOL FOAM, CARBON DIOXIDE,
WATER SPRAY.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SPILL WITH PAPER TOWEL OR SIMILAR
ABSORBENT AND PLACE IN DRY GARBAGE; OR FLUSH TO SEWER OR GROUND
WITH LARGE AMOUNTS OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR.
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
RUBBER APRON.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:1.00 (H*2O=1)
pH:10
Evaporation Rate & Reference:1.00 (H*2O=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR OR BLUE COLORED LIQUID; SLIGHT ODOR.
Percent Volatiles by Volume:100 WT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, OXIDIZERS OR ANY REACTIVE MATERIALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:AS PER LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DIGOXIN CRYSTALLINE, D6003
CAGE:21076
CAGE:21076
============= Composition/Information on Ingredients =============
Ingred Name:DIGOXIN; (DIGOXIN CRYSTALLINE) (SARA 302)
CAS:20830-75-5
RTECS #:IH6125000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL MOUSE): 17780 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY BE FATAL IF INHALED,
SWALLOWED/ABSORBED THRU SKIN. MAY CAUSE IRRIT. CAUSES STOM PAINS,
VOMIT, DIARR. TARGET ORGANS: HEART, GI SYS, NERVES. TARGET ORGAN
DATA: BRAIN & COVERINGS (RECORDINGS F ROM SPECIFIC AREAS OF CNS);
SENSE ORGANS & SPECIAL SENSES (VISUAL FIELD CHANGES); BEHAVIORAL
(CONVLS OR(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: EFT ON SEIZURE THRESHOLD; ANOREXIA,
HUMAN; CHANGE IN PSYCHOPHYSIOLOGICAL TESTS); CARD (ARRHYS; PULSE
RATE DECRD W/FALL IN BP; CHANGE IN RATE; OTHER CHANGES); VASCULAR
(OTHER CHANGES); LUNGS, THORAX/RESP (DYSPNAE); GI (NAUS/VOMIT);
SPECIFIC DEVELOPMENTAL ABNORMALITIES (BLOOD & LYMPHATIC SYS).
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF WATER
FOR AT LEAST 15 MINUTES WHILE REMOVING CONTAMINATED CLOTHING AND
SHOES. INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTIFICIAL RE SPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN.
CALL A PHYSICIAN. WASH CONTAMINATED CLOTHING BEFORE REUSE.
INGESTION: CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL POWDER,
ALCOHOL OR POLYMER FOAM.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH APPROVED SELF-CONTAINED BREATHING
A BAG AND HOLD FOR DISPOSAL. AVOID RAISING DUST. VENTILATE AREA AND
WASH SPILL SITE AFT ER MATERIAL PICKUP IS COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT BREATHE DUST. AVOID CONTACT
WITH EYES, SKIN AND CLOTHING. AVOID PROLONGED OR REPEATED EXPOSURE.
HIGHTLY TOXIC. KEEP TIGHTLY CLOSED.
Other Precautions:STORE IN A COOL, DRY PLACE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA . WEAR PROTECTIVE CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:>478F,>248C
Appearance and Odor:WHITE POWDER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF CARBON MONOXIDE, CARBON
DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE OR MIX THE MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. OBSERVE ALL FEDERAL, STATE, AND LOCAL
LAWS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DIESEL STARTING FLUID,LP-535,LP-5537
CAGE:78280
CAGE:78280
CAGE:0UKB6
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ETHER (CERCLA)
CAS:60-29-7
RTECS #:KI5775000
Fraction by Wt: 91%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:400 PPM
ACGIH TLV:400PPM/500STEL; 9495
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:ETHYLENE (SARA 313)
CAS:74-85-1
RTECS #:KU5340000
Fraction by Wt: 6.5%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:ASPHYXIANT; 9495
Ingred Name:ETHYL ALCOHOL (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9495
Ingred Name:2,6-DI-TERT-BUTYL-P-CRESOL/BHT (BUTYLATED HYDROXYTOLUENE)
CAS:128-37-0
RTECS #:GO7875000
Fraction by Wt: 1% PPM
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3; 9495
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV FOR DIETHYL ETHER IS 400 PPM.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, TEARING, REDNESS, DRYNESS OF SKIN
AND DEFATTING, DIZZINESS, HEADACHE, NAUSEA, VOMITING
Medical Cond Aggravated by Exposure:PERSONS WITH CHRONIC RESPIRATORY OR
SKIN DISEASES MAY BE AT AN INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IMMEDIATELY. EYES/SKIN:IMMEDIATELY
FLUSH WITH WATER FOR 15 MINUTES. HOLD EYELIDS OPEN. INHALED:REMOVE
TO FRESH AIR. PROVIDE CPR/OXYGEN IF NECESSARY. ORAL:DO NOT INDUCE
VOMITING E XCEPT ON ADVICE OF COMPETENT MEDICAL PERSONNEL. IF
CONSCIOUS, DRINK LARGE AMOUNT OF MILK/WATER. DO NOT DRINK SODIUM
BICABONATE/FRUIT JUICES. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:-49F,-45C
Lower Limits:1.9%
Upper Limits:48%
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, FOAM. COOL
FIRE-EXPOSED CONTAINERS WITH WATER SPRAY.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:EXTREMELY FLAMMABLE. OVERHEATED, CLOSED
CONTAINERS COULD EXPLODE DUE TO INTERNAL PRESSURE BUILDUP. VAPORS
MAY TRAVEL TO AN IGNITION SOURCE AND FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. CONTAIN AND PICK UP SPILL WITH
NON-FLAMMABLE ABSORBENT SUCH AS SAND, EARTH, VERMICULITE. GROUND
ALL HANDLING EQUIPMENTS. PREVE NT LIQUID FROM ENTERING SEWERS OR
WATERWAYS.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, WELL VENTILATED AREA
AWAY FROM SPARKS, FLAME, OTHER SOURCES OF IGNITION & INCOMPATIBLE
MATERIALS. DO NOT STORE ABOVE 175F.
Other Precautions:DO NOT EVAPORATE TO DRYNESS, PEROXIDE, IF PRESENT,
WILL CONCENTRATE AND MAY EXPLODE. AVOID VAPOR/MIST. AVOID CONTACT
WITH EYES & SKIN. FOR INDUSTRIAL USE ONLY. KEEP AWAY FROM REACH OF
CHILDREN. SMOKIN G SHOULD BE PROHIBITED IN STORAGE AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. IF TLV IS EXCEEDED OR
FOR SYMPTOMS OF OVER EXPOSURE, WEAR NIOSH-APPROVED ORGANIC VAPOR
RESPIRATOR OR AIR-PURIFYING RESPIRATOR. IN EMERGENCY, WEAR A
NIOSH-APPROVED POSITIVE-PRES SURE SELF-CONTAINED BREATHING
APPARATUS.
Ventilation:USE EXPLOSION-PROOF VENTILATION EQUIPMENT.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING, APRON, AND BOOTS IF SPILLS OR
SPLASHING CAN OCCUR.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:G2
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:94.0F,ETHER
Vapor Pres:5548
Vapor Density:2.6
Spec Gravity:0.695
Viscosity:NOT RELEVANT
Evaporation Rate & Reference:6.9 (N-BUTYL ACETATE=1)
Solubility in Water:MODERATE
Appearance and Odor:COLORLESS LIQUID - STRONG ETHEREAL (SWEET PUNGENT)
ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, SPARKS, HOT SURFACES, FLAME. TENDS
TO PRODUCE EXPLOSIVE PEROXIDE ON LONG STANDING IN PRESENCE OF AIR
AND LIGHT.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
ALDEHYDES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. DO NOT PUNCTURE, MUTILATE OR INCINERATE
CONTAINERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:E C G MARINE
CAGE:GCHEM
CAGE:GCHEM
============= Composition/Information on Ingredients =============
Ingred Name:BUTYL ALCOHOL; (N BUTANOL) (SARA 313) (CERCLA)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 0.03%
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IF INGESTED A TEMPORARY DIARRHEA
CONDITION WOULD OCCUR AS WITH A DETERGENT COMPOUND. SIGNS &
SYMPTOMS OF EXPOSURE:NOT A PRIMARY SKIN IRRITANT; NO INHALATION
PRECAUTIONS. DRY SKIN IF PROLONGED EX POSURE EXISTS.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:INGEST:DRINK FRESH WATER COPIOUSLY. CALL MD IMMEDIATELY .
INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP) .
SKIN:LOTION APPLICATION WILL CORRECT. FLUSH W/COPIOUS AMOUNTS OF
WATER. CALL MD . EYES:FLUSH WITH FRESH WATER FOR AT LEAST 15
MINUTES.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:0
Upper Limits:0
Extinguishing Media:NOT APPLICABLE. MEDIA SUITABLE FOR SURROUNDING FIRE
CONDITIONS .
Fire Fighting Procedures:NOT APPLICABLE. USE NIOSH/MSHA APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT APPLICABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP WITH FRESH WATER, RINSE THOROUGHLY
AND SEWER DISPOSAL OF RUN-OFF.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT INGEST.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE OTHER THAN NORMAL VENTILATION. NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST:SUFFICIENT.
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:SPILLS SHOULD BE IMMEDATELY ADDRESSED TO
PRECLUDE SLICK AREAS.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:235F,113C
Vapor Pres:10
Vapor Density:75F
Spec Gravity:1.171 (H*2O=1)
Evaporation Rate & Reference:0.1% (BUTYL ACETATE =1)
Solubility in Water:INFINITE
Appearance and Odor:PINK LIQUID, VISCOUS, MILD ALCOHOL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER SOLUBLE, DISSOLVES PETROLEUM SOLVENTS. NO SPECIAL PRECUATIONS.
Stability Condition to Avoid:NOT AFFECTED BY FREEZING. NO TOXIC VAPORS
FROM HEAT.
Hazardous Decomposition Products:NON-HAZARDOUS. BIODEGRADABLE WHOLE OR
IN PART.
==================== Disposal Considerations ====================
Waste Disposal Methods:SEWER. DISPOSAL MUST BE I/A/W FEDERAL, STATE &
LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.