text
stringlengths 595
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:NEOPRENE SYNTHETIC RUBBER WM-1
CAGE:IN612
CAGE:IN612
CAGE:1N612
============= Composition/Information on Ingredients =============
Ingred Name:1,3-BUTADIENE, 2-CHLORO-, POLYMERS; (POLYCHLOROPRENE)
CAS:9010-98-4
RTECS #:EI9460000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (TALC,
CONTAINING NO ASBESTOS FIBERS)
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: <1%
OSHA PEL:20 MPPCF
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:1,3-BUTADIENE, 2-CHLORO-; (2-CHLORO-1, 3-BUTADIENE) (SARA
313) (CERCLA)
CAS:126-99-8
RTECS #:EI9625000
OSHA PEL:25 PPM, S
ACGIH TLV:10 PPM, S
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL) LOW, >20,000 MG/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:VAPORS OR FUMES MAY BE HARMFUL AND
IRRITATING TO THE UPPER RESPIRATORY TRACT. NOT IRRITATING TO SKIN.
MECHANICAL IRRITATION TO EYES.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:UNKNOWN.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER FOR AT LEAST 15 MINUTES, REPEATEDLY
HOLDING EYELIDS OPEN TO ENSURE PROPER IRRIGATION. CONSULT MD.
SKIN:WASH AFFECTED AREA W/SOAP & WATER. LAUNDER CLOTHING BEFORE
REUSE. INHAL:REMOVE TO FRESH AIR. KEEP WARM & QUIET. GIVE
ARTIFICIAL RESPIRATION IF NOT BREATHING. CONSULT MD. INGEST:SEEK
MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:OC
Flash Point:>500F,>260C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . HYDROGEN CHLORIDE IS EVOLVED UNDER FIRE CONDITIONS.
Unusual Fire/Explosion Hazard:POTENTIAL ELECTROSTATIC CHARGE BUILD-UP
WHEN POURING CHIPS; GROUNDING OF EQUIPMENT IS RECOMMENDED.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP SPILLAGE & TRANSFER TO A CLOSED
CONTAINER FOR DISPOSAL. CONTAMINATED SURFACES CAN BE CLEANED
W/SOLVENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID INHALING HEATED VAPORS OR FUMES.
STORE IN A COOL PLACE. KEEP CONTAINERS TIGHTLY CLOSED DURING
STORAGE & TRANSPORT.
Other Precautions:READ BULLETIN NP-110.1, "TOXICITY & HANDLING
GUIDELINES FOR NEOPRENE" BEFORE USING NEOPRENE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR W/ORGANIC VAPOR
CARTRIDGE SHOULD BE USED WHEN VAPORS OR FUMES ARE GENERATED. USE
PROPER NIOSH APPROVED DUST MASK TO AVOID BREATHING FREE TALC LEFT
IN BAG.
Ventilation:VENTILATE TO MAINTAIN FUME & VAP LEVELS W/IN ESTABLISHED
SAFE STD. IF LOC EXHST IS BEING USED, CAPTURE VELOCITY (SUPDAT)
Other Protective Equipment:ANSI APPRVD EYE WASH FOUNTAIN & DELUGE
SHOWER . CHEM RESIST CLTHG. IF HOT MOLTEN MATL IS HNDLD, WEAR HEAT
(SUPDAT)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
VENT:OF 150-200 FPM IS RECOMMENDED. OTHER PROT EQUIP:RESISTANT CLOTHING
& FOOTWEAR.
================== Physical/Chemical Properties ==================
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OFF-WHITE CHIPS; MILD CHARACTERISTIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:HEATING TO 200C OR HIGHER; HYDROGEN
CHLORIDE IS EVOLVED AT THESE TEMPERATURES.
Hazardous Decomposition Products:CARBON MONOXIDE, HYDROGEN CHLORIDE,
CARBON DIOXIDE, SULFUR DIOXIDE, ORGANIC ACIDS, ALDEHYDES &
ALCOHOLS.
==================== Disposal Considerations ====================
Waste Disposal Methods:NOT A RCRA HAZARDOUS WASTE. DISPOSE OF I/A/W
LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CUTTING FLUID
CAGE:KO866
CAGE:4S446
CAGE:KO866
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM HYDROCARBON LUBRICANT
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT GIVEN FOR PRODUCT AS A WHOLE
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED OVEREXPOSURE OVER PEL/TLV
MAY DAMAGE LIVER AND KIDNEY AND CAUSE CENTRAL NERVOUS SYSTEM
EFFECTS, IRREGULAR HEART BEAT AND POSSIBLE DEATH IF TOO MUCH IS
INHALED. NO DATA AVAILABLE CONCERNING A CUTE EFFECTS.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:LIVER DAMAGE, KIDNEY DAMAGE, CNS EFFECTS,
IRREGULAR HEART BEAT, DEATH.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH WITH SOAP AND WATER. IF IRRITATION PERSIST, GET MEDICAL
ATTENTION. INH ALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. GET
MEDICAL ATTENTION. INGESTION: CALL PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>390F,>199C
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR SELF CONTAINED
BREATHING APPARATUS AND FULL PROTECTIVE GEAR. COOL TANKS AND
CONTAINERS EXPOSED TO FIRE WITH WATER.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:TRANSFER BULK OF MIXTURE INTO ANOTHER
CONTAINER. ABSORB RESIDUE WITH AN INERT MATERIAL SUCH AS EARTH,
SAND OR VERMICULITE. SWEEP UP AND DISPOSE OF AS SOLID WASTE IN
ACCORDANCE WITH ALL APPLICABLE REGU LATIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT HANDLE OR STORE AT TEMPERATURES
OVER MAZIMUM STORAGE TEMPERATURE: 100F. BEFORE USE, READ LABEL AND
MSDS. USE ONLY AS DIRECTED.
Other Precautions:USE WITH ADEQUATE VENTILATION. DO NOT EAT, DRINK OR
SMOKE IN WORK AREA. STORE IN CLOSED, PROPERLY LABELED CONTAINER
WHEN NOT IN USE. KEEP AWAY FROM FOOD. KEEP OUT OF REACH OF
CHILDREN. FOR PROFESSIONA L USE ONLY. NOT FOR HOUSEHOLD USE/RESALE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA CERTIFIED RESPIRATOR WITH ORGANIC
VAPOR CARTRIDGE IF VAPOR CONCENTRATIONS EXCEED A TWA/PEL OF 5 MG/M3
FOR MINERAL OIL MIST.
Ventilation:EXHAUST VENTILATION SUFFICIENT TO KEEP AIRBORNE
CONCENTRATIONS BELOW RESPECTIVE TLV'S.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:>625F,>329C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Decomp Temp:Decomp Text:NOT GIVEN
Vapor Pres:NEGLIGIBLE
Vapor Density:NIL
Spec Gravity:0.89
Viscosity:NOT GIVEN
Evaporation Rate & Reference:NEGLIGIBLE
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER LIQUID WITH PUNGENT, SULFUR TYPE ODOR
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, OPEN FLAMES
Hazardous Decomposition Products:CARBON AND PHOSPHORUS OXIDES, OXIDES
OF SULFUR
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:METHYL ALCOHOL, 15490-3
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ALCOHOL; (METHANOL)(SARA III)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 99.9%
OSHA PEL:200 PPM;250 STEL, S
ACGIH TLV:200 PPM;250 STEL, S
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT) 5628 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:MAY BE FATAL IF SWALLOWED.
HARMFUL IF INHALED/ABSORBED THRU SKIN. VAP/MIST IS IRRIT TO EYES,
MUC MEMBS & UPPER RESP TRACT. CAUSES SKIN IRRIT. EXPOS CAN
CAUSE:DMG TO EYES, LIVER, HEART & KIDNEYS;GI DISTURBS. MAY CAUSE
CONVLS. TARGET ORGS:EYES, KIDNEYS. CNTNS METHANOL. MAY BE
FATAL/CAUSE BLINDNESS(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:IF SWALLOWED. CANNOT BE MADE NONPOIS.
TARGET ORGAN DATA:SENSE ORGANS & SPECIAL SENSES (OPTIC NERVE
NEUROPATHY, VISUAL FIELD CHANGES); BEHAVIORAL (HDCH); LUNGS,
THORAX/RESP (DYSPNAE, OTHER CHA NGES); GI (NAUS/VOMIT).
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:IMMED FLUSH W/COPIOUS AMTS OF WATER FOR AT LST 15 MINS.
ASSURE ADEQ FLUSHING BY SEPARATING EYELIDS W/FINGERS. SKIN:IMMED
FLUSH W/COPIOUS AMTS OF WATER FOR AT LST 15 MINS WHILE REMOVING
CONTAM CLT HG & SHOES. DISCARD CONTAM CLTHG & SHOES. INHAL:REMOVE
TO FRESH AIR. IF NOT BRTHG GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE
OXYGEN. INGEST:WASH OUT MOUTH W/WATER PROVIDED PERSON IS CONSCIOUS.
CALL MD.
===================== Fire Fighting Measures =====================
Flash Point:52.0F,11.1C
Lower Limits:6%
Upper Limits:36%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER OR APPROPRIATE
FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:EXTREMELY FLAMMABLE. VAPOR MAY TRAVEL
CONSIDERABLE DISTANCE TO SOURCE OF IGNITION & FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. SHUT OFF ALL SOURCES OF IGNIT.
W/DRY-LIME, SAND/SODA ASH. PLACE IN COVERED CNTNRS USING
NON-SPARKING TOOLS & TRANSPORT O UTDOORS. VENTILATE AREA & WASH
SPILL SITE (SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT BREATHE VAP. AVOID CONT W/EYES,
SKIN & CLTHG. AVOID PRLNG/RPTD EXPOS. DO NOT USE IF SKIN IS
CUT/SCRATCHED. POIS. IRRIT. HYGROSCOPIC. FLAMM.
Other Precautions:KEEP CNTNR TIGHTLY CLSD. KEEP AWAY FROM HEAT, SPKS &
OPEN FLAME. STORE IN COOL, DRY PLACE. TOX. MAY BE FATAL/CAUSE
BLINDNESS IF SWALLOWED. VAP HARMFUL. CANNOT BE MADE NON-POIS.
CAUSES IRRIT. KEEP AWAY FROM SOURCES OF IGNIT. NO SMOKING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:WEAR OTHER PROTECTIVE CLOTHING. SAFETY
SHOWER & EYE BATH.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
SPILL PROC:AFTER MATERIAL PICKUP IS COMPLETE.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:148F,65C
Melt/Freeze Pt:M.P/F.P Text:-144F,-98C
Vapor Pres:97.68 @20C
Vapor Density:1.1
Spec Gravity:0.791
Appearance and Odor:COLORLESS LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, ACID CHLORIDES, ACID ANHYDRIDES, OXIDIZING AGENTS, REDUCING
AGENTS, ALKALI METALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF: CARBON MONOXIDE,
CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . BURN IN A CHEMICAL INCINERATOR EQUIPPED W/AFTERBURNER
& SCRUBBER BUT EXERT EXTRA CARE IN IGNITING AS THIS MATERIAL IS
HIGHLY FLAMMABLE .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:56530 NEU-TRI SOLVENT
CAGE:96717
CAGE:60777
CAGE:96717
============= Composition/Information on Ingredients =============
Ingred Name:TRICHLOROETHYLENE (SARA III)
CAS:79-01-6
RTECS #:KX4550000
Fraction by Wt: 99.4%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM; Z-2
ACGIH TLV:50 PPM/100STEL,A5;94
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:1,2-BUTYLENE OXIDE (SARA III)
CAS:106-88-7
RTECS #:EK3675000
Fraction by Wt: 0.5%
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:STABILIZERS
Fraction by Wt: 0.1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT ESTABLISHED.
ACGIH TLV:NOT ESTABLISHED.
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS 4920 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION MAY IRRITATE
RESPIRATORY TRACT; PRODUCE SYSTEMIC EFFECTS. CONTACT MAY IRRITATE
EYES. ASPIRATION MAY CAUSE INJURY TO BODY SYSTEMS. CHRONIC:
PROLONGED OR REPEATED EXPOSURE MAY CAUSE SK IN IRRITATION.
Explanation of Carcinogenicity:IARC LISTS TRICHLORETHYLENE AS
UNCLASSIFIABLE (3) AS TO CARCINOGENICITY.
Effects of Overexposure:EYES-PAIN, REDNESS, TEARING, BLURRED VISION.
SKIN-DRYING, REDNESS, FLAKING OF SKIN. INHALED-COUGHING, WHEEZING,
SHORTNESS OF BREATH, DIZZINESS, DRUNKENESS, UNCONSCIOUSNESS, DEATH;
IRREGULAR HEART BEAT S; SENSITIVITY TO EPINEPHRINE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGESTED-CALL A PHYSICIAN AND/OR TRANSPORT TO EMERGENCY
FACILITY IMMEDIATELY. DO NOT INDUCE VOMITING! INHALED-REMOVE TO
FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING DIFFICULT , GIVE OXYGEN. CALL A DOCTOR. SKIN-REMOVE
CONTAMINATED CLOTHES. FLUSH SKIN WITH LOTS OF WATER.
EYES-IMMEDIATELY FLUSH WITH LOTS OF WATER FOR AT LEAST 15 MINUTES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:788F
Lower Limits:8.0
Upper Limits:44.8
Extinguishing Media:WATER FOG
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR FULL PROTECTIVE
CLOTHING INCLUDING POSITIVE-PRESSURE SELF-CONTAINED BREATHING
APPARATUS.
Unusual Fire/Explosion Hazard:STRONG UNPLEASANT ODOR. AUTOIGNITION
TEMPERATURE IS 788F/420C.
================== Accidental Release Measures ==================
Spill Release Procedures:MOP UP, WIPE UP OR SOAK UP IMMEDIATELY.
TRANSFER TO CLOSED METAL CONTAINERS. KEEP OUT OF WATER SUPPLY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE WITH REASONABLE CARE. AVOID
BREATHING VAPORS.STORE IN COOL PLACE. VAPORS OF THIS PRODUCT ARE
HEAVIER THAN AIR & WILL COLLECT IN LOW AREAS.
Other Precautions:VAPORS WILL COLLECT IN LOW AREAS SUCH A SPITS,
DEGREASERS, STORGAE TANKS AND OTHER CONFINED AREAS. DO NOT ENTER
THESE AREAS WHERE VAPORS ARE SUSPECTED UNLESS SCBA IS USED AND AN
OBSERVER IS PRESENT FO R ASSISTANCE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE
OR EMERGENCY OCCURS; USE NIOSH/MSHA APPROVED RESPIRATOR OR SUPPLIED
AIR RESPIRATOR OR SCBA, AS REQUIRED. USE IAW 29 CFR 1910.134 AND
MANUFACTURER'S RECO MMENDATIONS.
Ventilation:USE ONLY WITH ADEQUATE VENTILATION. USE ADEQUATE MECHANICAL
VENTILATION OR LOCAL EXHAUST TO MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment:USE IMPERVIOUS PROTECTIVE CLOTHING TO
PREVENT PROLONGED OR REPEATED SKIN CONTACT.DLA-HMIS:EYE WASH
STATION/SAFETY SHOWER
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
NOTE TO PHYSICIANS:DO NOT ADMINISTER SYMPATHOMETRIC DRUGS UNLESS
ABSOLUTELY NECESSARY (DUE TO CARDIAC IRRATIBILTY).
================== Physical/Chemical Properties ==================
HCC:T4
Boiling Pt:B.P. Text:189F,87C
Vapor Pres:60 MM HG
Vapor Density:4.53
Spec Gravity:1.46
Solubility in Water:NEGLEGIBLE
Appearance and Odor:COLORLESS LIQUID, IRRITATING ODOR AT HIGH
CONCENTRATIONS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES (EG. CAUSTIC SODA, CAUSTIC POTASH). ALUMINUM AND ZINC
POWDERS.
Stability Condition to Avoid:AVOID OPEN FLAMES, WELDING ARCS, HIGH
TEMP. SOURCES.
Hazardous Decomposition Products:CHLORINE, PHOSGENE, HYDROGEN CHLORIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:SEND SOLVENT TO A LICENSED RECLAIMER OR
PERMITTED INCINERATOR. DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS. DLA-HMIS:EPA/RCRA WASTE NUMBER U228
(TRICHLOROETHYLENE) MAY APPLY TO UNUSED/UNCONTAMINATED PRODUCT.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ISOPROPYL ALCOHOL (ISOPROPANOL)
CAGE:2H215
CAGE:2H215
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 100%
Other REC Limits:NONE SPECIFIED BY M.
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RAT LD50:5840 MG/KG,RABBIT:13G/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATION OF EYES,SKIN AND
RESPIRATORY TRACT; CNS EFFECTS, DROWSINESS, HEADACHE, STAGGERING,
DRYING OF SKIN. INGESTION MAY CAUSE NAUSEA, G.I. TRACT PAIN,
VOMITING & DIARRHEA, UNCONSCIOUSNESS AN D DEATH. CHRONIC: CNS
DEPRESSION.
Effects of Overexposure:IRRITATION OF EYES, NOSE, THROAT; DROWSINESS;
DIZZINESS; HEADACHE; DRY CRACKING SKIN; GI CRAMPS; NAUSEA;
DIARRHEA.
Medical Cond Aggravated by Exposure:EYE, SKIN AND RESPIRATORY
DISORDERS.
======================= First Aid Measures =======================
First Aid:SKIN: REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER.
APPLY SKIN CREAM IF DEFATTING OF SKIN OCCURES. INHALATION: REMOVE
TO FRESH AIR AT ONCE. RESUSCITATE IF BREATHING STOPPED. GET MEDICAL
ATTE NTION. EYE: IMMEDIATELY FLUSH WITH WATERFOR 15 MINUTES WHILE
HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION. INGESTION: GET
IMMEDIATE MEDICAL ATTENTION. DO NOT INDUCE VOMITING. MED: GIVE
GASTRIC LAVAGE.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:53.6F,12.0C
Autoignition Temp:Autoignition Temp Text:750F
Lower Limits:2
Upper Limits:12.7%
Extinguishing Media:CO2,DRY CHEM,ALCOHOL FOAM
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR PROTECTIVE CLOTHING
AND SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:FLAMMABLE LIQUID;MODERATE EXPLOSION
HAZARD WHEN EXPOSED TO HEAT OR FLAMES.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIM IGNIT SOURCES.VENT AREA.STOP LEAK W/O
RISK.WEAR SCBA.ABSORB SM QTY W/INERT MATL AND PLACE IN CLOSED
DISPOSAL DRUM.DIKE LG QTY AND PUMP/VACUUM INTO CLOSED DRUM FOR
RECLAIM/DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED AREA
AWAY FROM HEAT & IGNIT SOURCES.KEEP CONTAIN CLOSED WHEN NOT IN
USE.PROTECT FM DAMAGE.DO NOT INGEST/INHAL.
Other Precautions:DO NOT EAT OR SMOKE IN AREA OF USE OR STORAGE. AVOID
SKIN/EYE CONTACT. LAUNDER CONTAMINATED CLTHG BEFORE REUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR FOR ORGANIC
VAPORS.
Ventilation:MECHANICAL REQD,LOCAL RECOMMENDED FOR CLOSED AREAS.
Other Protective Equipment:AS REQUIRED TO AVOID SKIN CONTACT;EYEWASH,
SAFETY SHOWER.
Work Hygienic Practices:AVOID CONTACT WITH EYES AND SKIN;DO NOT BREATHE
VAPORS/MIST;NO SMOKING IN WORK AREA.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:181F,83C
Melt/Freeze Pt:M.P/F.P Text:-128F/-89C
Vapor Pres:33 MMHG
Vapor Density:2.1
Spec Gravity:0.79
Evaporation Rate & Reference:3 (BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR COLORLESS LIQUID, ALCOHOLIC ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:HIGH HEAT AND IGNITION SOURCES SUCH AS
OPEN FLAME OR SPARKS.
Hazardous Decomposition Products:CARBON MONOXIDE,CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR DISPOSE OF I/A/W ALL LOCAL,STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PRENTOX DURSBAN 4E
CAGE:86586
Contract Num:SP0450-99-M-NG74
CAGE:8C885
Contract Num:SP0450-99-M-NJ94
CAGE:8C885
Contract Num:SP0450-99-MC457
CAGE:8C885
CAGE:0TNN7
CAGE:86586
============= Composition/Information on Ingredients =============
Ingred Name:CHLORPYRIFOS (CERCLA)
CAS:2921-88-2
RTECS #:TF6300000
= Wt:44.8
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S, 0.2 MG/M3
ACGIH TLV:S, 0.2 MG/M3; 9596
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:XYLENE RANGE AROMATIC SOLVENT ( CONTAINS INGREDIENTS 3, 4,
5 AND 6.)
CAS:64742-95-6
RTECS #:WF3400000
= Wt:46.3
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 AS OIL MIST
ACGIH TLV:5 MG/M3 AS OIL MIST
Ingred Name:1,2,4-TRIMETHYLBENZENE (SARA 313); PART OF ING 2
CAS:95-63-6
RTECS #:DC3325000
= Wt:32.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:25 PPM
ACGIH TLV:25 PPM; 9596
Ingred Name:MIXED XYLENES (SARA 313) (CERCLA); PART OF ING 2
CAS:1330-20-7
RTECS #:ZE2100000
= Wt:3.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:CUMENE (SARA 313) (CERCLA); PART OF ING 2
CAS:98-82-8
RTECS #:GR8575000
= Wt:1.5
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 50 PPM; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL BENZENE (SARA 313); PART OF ING 2
CAS:100-41-4
RTECS #:DA0700000
= Wt:.5
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/125STEL;9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:EMULSIFIERS (1)
= Wt:3.
Other REC Limits:NONE RECOMMENDED
Ingred Name:EMULSIFIERS (2)
= Wt:3.
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE AND CHRONIC - MAY BE FATAL IF
SWALLOWED/ABSORBED THROUGH SKIN. EXPOSURE TO EXTREMELY HIGH LEVELS
OF XYLENE MAY CAUSE KIDNEY DAMAGE OR LIVER DAMAGE. INHALATION OF
SOLVENT VAPORS AT HIGH CENCENTRA TIONS CAN CAUSE CENTRAL NERVOUS
SYSTEM DEPRESSION, RESPIRATORY TRACT IRRITATION, ASPHYXIATION,
CARDIAC STRESS, AND COMA. SOLVENT MAY PRESENT ASPIRATION HAZARD.
Explanation of Carcinogenicity:NONE.
Effects of Overexposure:WEAKNES, HEADACHE, LIGHTHEADEDNESS, TIGHTNESS
IN CHEST, BLURRED VISION, NON-REACTIVE PUPILS, SWEATING, NAUSEA,
VOMITING, DIARRHEA AND ABDOMINAL CRAMPS.
Medical Cond Aggravated by Exposure:PREEXISTING CONDITIONS WHICH LOWER
CHOLINESTERASE DEFFICIENCY, ADVANCES LIVER DISEASE, CHRONIC
ALCOHOLISM, MALNUTRITION, ORGAINC MERCURY COMPOUNDS AND HEMOLYTIC
ANEMIAS.
======================= First Aid Measures =======================
First Aid:IF SWALLOWED: CALL A PHYSICIAN OR POISON CONTROL CENTER
IMMEDIATELY. CONTAIN PETROLEUM DISTILLATES. DO NOT INDUCE VOMITING.
GET MEDICAL ATTENTION IMMEDIATELY. IF INHALED: REMOVE PERSON TO
FRESH AIR. A PPLY ARTIFICIAL RESPIRATION IF SYMPTOMSINDICATE. IF ON
SKIN: WASH AFFECTED AREAS WITH SOAP & WATER. IF IN EYES: FLUSH EYES
WITH PLENTY OF WATER. GET PROMPT MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:=43.9C, 111.F
Lower Limits:1.9
Upper Limits:12.6
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:FIGHT FIRE FROM UPWIND POSITION. USE
SELF-CONTAINED BREATHING APPARATUS & EQUIPMENT DESIGNED TO PREVENT
SKIN & EYE CONTACT. COOL EXPOSED CONTAINERS WITH WATERSPRAY. THIS
PRODUCT IS TOXIC TO FISH, BIRD S AND OTHER WILDLIFE. PREVENT SPREAD
OFCONTAMINATED RUNOFF.
Unusual Fire/Explosion Hazard:MAY GIVE OFF HYDROGEN CHLORIDE, ETHYL
SULFIDE, DIETHYL SULFIDE & NITROGEN OXIDES. FOAM IS PREFERRED
METHOD OF FIGHTING FIRES TO HELP PREVENT SPREAD OF RUNOFF.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT, AS REQUIRED, TO
PREVENT CONTACT WITH PRODUCT OR ITS VAPORS. COVER THE SPILLED
MATERIAL WITH GENEROUS AMOUNTS OF ABSORBENT MATERIAL. SWEEP THE
CONTAMINATED ABSORBENT ONTO A SHOVEL AND PUT THE SWEEPING INTO A
SALVAGE DRUM. PLACE ANY LEAKING CONTAINER INTO ANOTHER SALVAGE
DRUM.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A DRY PLACE AWAY FROM
TEMPERATURE EXTREMES. AVOID INHALATION OF VAPORS. AVOID CONTACT
WITH SKIN. WEAR CLEAN PROTECTIVE CLOTHING. DO NOT USE OR STORE NEAR
HEAT OR OPEN FLAMES. CARE SHOULD BE T AKEN TO AVOID DEPOSITING THE
PRODUCT ONTO EXPOSED SURFACES & IN AIR. AVOID CONTAMINATION OF
FOOD.
Other Precautions:DO NOT CONTAMINATE WATER, FOOD OR FEED BY STORAGE OR
DISPOSAL. CAUSES EYE DAMAGE. PERIODICALLY INSPECT STORED MATERIAL.
CAUSES EYE DAMAGE. DO NOT GET IN EYES. IF PRODUCT IS DILUTED WITH
WATER, DO NOT USE IN CONDUITS, MOTOR HOUSINGS AND ELECTRICAL
SWITCH BOXES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A PESTICIDE RESPIRATOR JOINTLY APPROVED BY
MSHA/NIOSH. UNDER PROVISIONS 0F 30CRF PART II.
Ventilation:LOCAL EXHAUST, SPECIAL, MECHANICAL, OTHER: AS REQUIRED TO
MEET TLV VALUES.
Other Protective Equipment:FULL PROTECTIVE CLOTHING DESIGNED TO PREVENT
SKIN CONTACT SUCH AS RESISTANT OVERALLS.
Work Hygienic Practices:MAY BE FATAL IF INHALED OR ABSORBED THROUGH
SKIN. DO NOT BREATHE FUMES. RAPIDLY ABSORBED THROUGH SKIN.WASH
HANDS AND FACE WITH SOAP AND WATER BEFORE EATING OR SMOKING.
Supplemental Safety and Health
PESTICIDE.
================== Physical/Chemical Properties ==================
HCC:F5
Spec Gravity:1.0674
Solubility in Water:EMULSIFIES
Appearance and Odor:YELLOW LIQUID, MILD MERCAPTAN ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALIS.
Stability Condition to Avoid:CHLORPYRIFOS UNDERGOES EXOTHERMIC
DECOMPOSITION AT ABOUT 130C(266F) WHICH CAN LEAD TO HIGHER TEMPS
AND VIOLENT DECOMPOSITION. IF HEAT MOT REMOVED. THE SOLVENT
INPRODUCT WILL BURN.
Hazardous Decomposition Products:HYDROGEN CHLORIDE, ETHYL SULFIDE,
DIETHYL SULFIDE AND NITROGEN OXIDES.
===================== Ecological Information =====================
Ecological:THIS PRODUCT IS HIGHLY TOXIC TO BEES EXPOSED TO DIRECT
TREATMENT OR RESIDUE ON PLANTS. PROTECTIVE INFORMATION MAY BE
OBTAINED FROM YOUR COORPERATIVE AGRICULTURAL EXTENSION SERVICE.
DURSBAN 4E IS ALSOTOXIC TO FISH, BIRDS AND OTHER WILDLIFE.FOR
TERRESTRIAL USES, DO NOT APPLY DIRECTLY TO WATER OR TO AREAS WHERE
SURFACE WATER IS PRESENT OR TO INTERTIDAL AREAS BELOW THE MEAN HIGH
WATER MARK. DO NOT CO NTAMINATE WATER BY CLEANING OF EQUIPMENT OR
DISPOSAL WASTES.
==================== Disposal Considerations ====================
Waste Disposal Methods:PESTICIDE WASTE ARE TOXIC. IF THESE WASTES
CANNOT BE DISPOSED OF BY THE USE ACCORDING TO LABEL INSTRUCTIONS,
CONTACT YOUR STATE PESTICIDE OE ENVIRONMENTAL CONTROL AGENCY.
=================== MSDS Transport Information ===================
Transport Information:E.P.A. REG. NO. 655-499.
===================== Regulatory Information =====================
SARA Title III Information:THIS PRODUCT CONTAINS A TOXIC CHEMICAL OR
CHEMICALS (<>) TO THE REPORTING REQUIREMENTS OF SECTION 313 OF
TITLE IIIAND OF 40 CFR 372. ANY COPIES OR REDISTRIBUTION OF THIS
MSDS MUST INCLUDE THIS POLICE.
Federal Regulatory Information:EPA REGISTRATION NO: 655-499.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DRY IT
CAGE:FO988
CAGE:FO988
============= Composition/Information on Ingredients =============
Ingred Name:HYDROFLUOSILIC ACID
CAS:16961-83-4
RTECS #:VV8225000
Fraction by Wt: <4%
Other REC Limits:2.5 MG/CUM
OSHA PEL:2.5 MG/CUM
ACGIH TLV:2.5 MG/CUM
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: <6%
Other REC Limits:400 PPM
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:1,2-PROPANEDIOL (PROPYLENE GLYCOL)
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: <2%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: MILD CHAPPING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: MILD CHAPPING.
======================= First Aid Measures =======================
First Aid:SKIN/EYES: WASH OFF W/PLENTY OF WATER. OBTAIN MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:COLLECT MATERIAL FOR REUSE OR PROPER DISPOSAL,
WASH REMAINDER W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY CLOSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:NORMAL LOCAL EXHAUST
Other Protective Equipment:NONE
Work Hygienic Practices:NONE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Spec Gravity:0.98
Evaporation Rate & Reference:(BU AC = 1): <1
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT BLUE SYRUPLY LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DILUTE W/PLENTY OF WATER TO DISPOSE SMALL AMOUNT
INTO THE SEWER IN ACCORDANCE W/LOCAL, STATE, & FEDERAL REGULATIONS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:4400 0169 LUMINOMETER VALIDATION KIT
Kit Part:Y
CAGE:015J7
CAGE:015J7
============= Composition/Information on Ingredients =============
Ingred Name:TRIS (2,3-DIBROMOPROPYL) PHOSPHATE
CAS:126-72-7
RTECS #:UB0350000
Fraction by Wt: 10%
Ingred Name:ALKALINE PHOSPHOTASE
Fraction by Wt: 0.01%
Ingred Name:MAGNESIUM CHLORIDE
CAS:7786-30-3
Fraction by Wt: 1%
Ingred Name:SODIUM CHLORIDE * 96-3 *
CAS:7647-14-5
RTECS #:VZ4725000
Ingred Name:ZINC CHLORIDE
CAS:7646-85-7
RTECS #:ZH1400000
OSHA PEL:1 MG/CUM
ACGIH TLV:1 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HYDROCHLORIC ACID, HYDROGEN CHLORIDE, MURIATIC ACID
HYDROCHLORIDE
CAS:7647-01-0
RTECS #:MW4025000
Fraction by Wt: 0.01%
Other REC Limits:7 PPM
OSHA PEL:5 PPM
ACGIH TLV:C 11 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TRIS: INHALATION: SLIGHT IRRITATION TO
TISSUES OF THE MUCOUS MEMBRANES & UPPER RESPIRATORY TRACT. CAUSES
SKIN & SEVERE EYE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/COPIOUS QUANTITIES OF WATER FOR 15 MINS.
INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN/CPR IF NECESSARY.
SKIN: FLUSH W/COPIOUS QUANTITIES OF WATER FOR 15 MINS. INGESTION:
WASH OUT MOUTH W /WATER. OBTAIN MEDICAL ATTENTION IN ALLCASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE TO THE
SURROUNDING FIRE CONDITIONS.
Fire Fighting Procedures:USE SELF CONTAINED BREATHING APPARATUS & WEAR
PROTECTIVE CLOTHING TO PREVENT CONTACT W/EYES & SKIN.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
COVER W/SAND/OTHER NONCOMBUSTIBLE ABSORBENT MATERIAL. TAKE UP &
DISPOSE OF PROPERLY. WASH AREA WELL W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP TIGHTLY CLOSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATORY EQUIPMENT REQUIRED
Other Protective Equipment:SUITABLE PROTECTIVE CLOTHING, SAFETY SHOWER,
EYEWASH
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Pres:AS WATER
pH:7.6
Evaporation Rate & Reference:(WATER=1): 1
Solubility in Water:MISCIBLE
Appearance and Odor:A CLEAR COLORLESS LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING & REDUCING AGENTS, STRONG ACIDS. AZIDE REACTS W/LEAD,
COPPER, MERCURY TO FORM EXPLOSIVE COMPOUNDS.
Hazardous Decomposition Products:CO, CO2, NITROGEN OXIDES, HYDROGEN
BROMIDE & HYDROGEN CHLORIDE GASES
==================== Disposal Considerations ====================
Waste Disposal Methods:SMALL: FLUSH THE AQUEOUS SOLUTIONS DOWN THE
DRAIN W/A COPIOUS QUANTITY OF WATER. DISPOSE OF IN ACCORDANCE
W/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SZ-13, SZ13500
Preparer's Name:GASTON L PILLORI
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:ING 7: GET MED ATTN IMMED. EYES: WASH IMMED W/LARGE AMTS OF
WATER, OCCAS LIFTING UPPER/LOWER LIDS, UNTIL NO (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: EVIDENCE OF CHEM REMAINS (A MINIMUM OF 15 MIN). IN
CASE OF BURNS, APPLY STERILE BANDAGES LOOSELY W/OUT (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: MEDICATION. GET MED ATTN IMMED. INGEST: IF
CONSCIOUS, GIVE LGE QTYS OF WATER IMMED TO DILUTE THE ACID. (ING
11)
RTECS #:9999999ZZ
Ingred Name:ING 10: DO NOT INDUCE VOMITING. GIVE 1 OUNCE (30 ML) OF
MILK OF MAGNESIA. GET MED ATTN IMMED.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: IN CASE OF CHEM BURNS, COVER AREA
W/STERILE, DRY DRESSING. BANDAGE SECURELY, BUT NOT TOO TIGHTLY.(ING
8)
RTECS #:9999999ZZ
Ingred Name:NITRIC ACID
CAS:7697-37-2
RTECS #:QU5775000
Fraction by Wt: 6.5%
OSHA PEL:2 PPM; 4 PPM STEL
ACGIH TLV:2 PPM; 4 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER. VP: 14. VAP DENS: 0.7.
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 93.4%
Ingred Name:ZINC OXIDE
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: 0.1%
OSHA PEL:15MG/M3 TDUST/5 FUME
ACGIH TLV:10MG/M3 TDUST; 9293
Ingred Name:EFTS OF OVEREXP: PERFORATION OF THE ESOPHAGUS & STOMACH
WHICH MAY BE FOLLOWED BY MEDIASTINITIS OR PERITONITIS, (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: INDICATED BY FEVER. CHRONIC: INHAL: SEE ACUTE EXPOS.
SKIN: RPTD/PRLNG CONTACT MAY CAUSE DERMATITIS. (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: EYE: REPEATED OR PROLONGED EXPOSURE MAY CAUSE
CONJUNCTIVITIS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CORROSIVE. INHAL: 100PPM, ARE
IMMED DANGEROUS TO LIFE/HLTH. NO INHAL EFTS ARE ANTIC IN THE
PROPOSED(ANALYTICAL) USE OF THIS SOLN. SKIN: IMMED, SEV &
PENETRATING BURNS. EYE: DIRECT CONT W/ THE L IQ CAUSES PAIN,
PHOTOPHOBIA, TEARING, EDEMA, CORNEAL ULCERATION, SEV BURNS &
NECROSIS OF THE DEEPER TISS (EFTS OF OVEREX
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: W/PERM DMG. INGEST:IMMED PAIN IN THE
MOUTH, THROAT, & STOM MAY BE FOLLOWED BY NAUS, VOMIT, DIARR,
HEMATEMESIS, HEMOPTYSIS, HYPOTENSION, NEPHRITIS, ALBUMINURIA,
OLIGURIA, ANURIA, HEMATURIA, & POSS CIRCULATORY COLLAPSE. ASPHYXIA
FROM GLOTTAL EDEMA IS POSS. BURNS OF GI TRACT MAY BE SEV ENOUGH TO
CAUSE (ING 4)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM EXPOS AREA TO FRESH AIR IMMED. IF BRTHG
HAS STOPPED, GIVE ARTF RESP. MAINTAIN AIRWAY/BLOOD PRESS & ADMIN
OXYGEN IF AVAIL. KEEP WARM & AT REST. ADMIN OF OXYGEN SHLD BE
PERFORMED BY Q UALIFIED PERS. GET MED ATTN IMMED. SKIN: REMOVE
CONTAM CLTHG/ SHOES IMMED. WASH AFFECTED AREA W/SOAP OR MILD
DETERGENT & LGE AMTS OF WATER UNTIL NO EVIDENCE OF CHEM REMAINS (AT
LEAST 15 MIN). (ING 7)
===================== Fire Fighting Measures =====================
Flash Point:WILL NOT BURN
Extinguishing Media:DRY CHEMICAL, CO2, WATER SPRAY OR FOAM. FOR LARGER
FIRES, USE WATER SPRAY, FOG OR ALCOHOL FOAM.
Fire Fighting Procedures:MOVE CONTRS FROM FIRE AREA IF POSS. COOL
CONTRS EXPOSED TO FLAMES W/WATER FROM SIDE UNTIL WELL AFTER FIRE IS
OUT. EXTINGUISH USING AGENTS INDICATED. (SUPP DATA)
Unusual Fire/Explosion Hazard:NEGLIGIBLE FIRE & EXPLOSION HAZARD WHEN
EXPOSED TO HEAT/FLAME. HOWEVER, CONTACT WITH COMMON METALS CAUSES
EVOLUTION OF FLAMMABLE GAS.
================== Accidental Release Measures ==================
Spill Release Procedures:OCCUP SPILL: PROVIDE VENT. WEAR PERSONAL PROT
EQUIP. COVER W/SODA ASH. SCOOP UP & PLACE IN A SUITABLE CONTR.
CLOSE TIGHTLY & LABEL CORROSIVE. KEEP OUT OF SEWERS, WATERWAYS &
OTHER WATER SOURCES.
Neutralizing Agent:SEE SPILL/RELEASE PROCEDURES.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID STORAGE WITH INCOMPATIBLE
MATERIALS.
Other Precautions:CORROSIVE. DO NOT WEAR CONTACT LENSES WHEN WORKING
WITH CHEMICALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED IN THE PROPOSED (ANALYTICAL) USE
OF THIS SOLUTION. IF NEEDED, USE NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:PROVIDE GENERAL DILUTION VENTILATION TO MEET PUBLISHED
EXPOSURE LIMITS. VENTILATION EQUIPMENT MUST BE EXPLOSION-PROOF.
Other Protective Equipment:IMPERVIOUS CLTHG/EQUIP TO PVNT POSSIBILITY
OF SKIN CONT. EMER EYE-WASH & DELUGE SHOWER W/IN THE IMMED WORK
AREA.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC: AVOID SPLASHING/SPATTERING THIS MATL. IF LGE AMTS OF
COMBUST MATLS ARE INVOLVED, USE WATER SPRAY/FOG IN FLOODING AMTS.
USE WATER SPRAY TO ABSORB CORR VAPS. COOL CONTRS W/ FLOODING AMT S
OF WATER FROM AS FAR A DIST AS POSS. WEAR NIOSH/MSHA APPRVD
SCBA/FULL PROT EQUIP . CNDTNS(STAB):W/INCOMPAT MATLS
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Vapor Pres:SEE ING 2
Vapor Density:SEE ING 2
Spec Gravity:1.1
pH:<0.01
Evaporation Rate & Reference:>1 (ETHER = 1)
Solubility in Water:MISCIBLE
Appearance and Odor:COLORLESS LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SEE ORIGINAL MSDS.
Stability Condition to Avoid:AVOID HEATING TO THE BP, WHERE EMISSION OF
CORR MIST/VAP OCCURS. AVOID LEAKY/CORRODIBLE CONTRS. AVOID CONT
(SUPP DATA)
Hazardous Decomposition Products:ON BOILING, EMITS CORROSIVE MIST AND
NOX AS VAPORS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE, AND LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PERMADYNE ADHESIVE
CAGE:08675
CAGE:08675
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 20%
Other REC Limits:100 PPM
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 71%
Other REC Limits:590 MG/CUM
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE IRRITATION OF
THE RESPIRATORY TRACT, DIZZINESS, UNCONSCIOUSNESS. EYES/SKIN:
IRRITATION. INGESTION: MAY CAUSE STOMACH-ACHE, NAUSEA, VOMITING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: MAY CAUSE IRRITATION OF THE
RESPIRATORY TRACT, DIZZINESS, UNCONSCIOUSNESS. EYES/SKIN:
IRRITATION. INGESTION: MAY CAUSE STOMACH-ACHE, NAUSEA, VOMITING,
LIVER/KIDNEY DAMAGE, & CENTRAL NERVOU S SYSTEM DISTURBANCES.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/FLOWING WATER, CONSULT PHYSICIAN. SKIN: WASH
AREA W/MILD SOAP & WATER. IF RASH RESULTS, CONSULT PHYSICIAN.
INHALATION: SUPPLY FRESH AIR, IF REQUIRED OXYGEN, CONSULT
PHYSICIAN. INGESTION: CONSULT PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:25F
Lower Limits:1%
Upper Limits:7%
Extinguishing Media:CO2, SPRINKLE WATER, DRY CHEMICAL
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR FULL PROTECTIVE
CLOTHING INCLUDING A SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:DURING A FIRE, IRRITATING/TOXIC GASES &
AEROSOLS MAY BE PRESENT FROM THE DECOMPOSITION/COMBUSTION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/INERT MATERIAL & DISCARD IN A CLOSED
CONTAINER. REMOVE ALL SOURCES OF IGNITION & VENTILATE AREA.
======================Handling and Storage ======================
Handling and Storage Precautions:ALWAYS CLOSE CONTAINER IMMEDIATELY
AFTER USE & KEEP AWAY FROM HEAT SOURCES & OPEN FLAMES. STORE IN A
COOL, DRY AREA AWAY FROM FOODSTUFF & BEVERAGES.
Other Precautions:HANDLING OF THE PRODUCT EXCLUSIVELY BY DENTAL
SPECIALISTS. FOLLOW THE INSTRUCTIONS FOR USE. AVOID CONTACT W/SKIN
& EYES.
============= Exposure Controls/Personal Protection =============
Work Hygienic Practices:CLOSE CONTAINER AFTER USE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:176F
Vapor Pres:79
Vapor Density:>1.0
Spec Gravity:<1.0
Evaporation Rate & Reference:(BU AC = 1): >1.0
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLUE-GREEN LIQUID, CHARACTERISIC ODOR (ORGANIC
SOLVENTS)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:HEAT SOURCES & OPEN FLAMES.
Hazardous Decomposition Products:IRRITATING/TOXIC GASES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE CARRIED OUT IN ACCORDANCE WITH
FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DARCO, NORIT, ACTIVATED CHARCOAL, CX0662
CAGE:0SK29
CAGE:0SK29
CAGE:0AL61
============= Composition/Information on Ingredients =============
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:ORAL(RAT)>10 G/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION MAY IRRITATE NASAL AND
RESPIRATORY PASSAGES. MAY IRRITATE EYES ON CONTACT. ACTIVATED
CHARCOAL IS FREQUENTLY CONTAMINATED WITH IMPURITIES WHICH MAY BE
IRRITATING AND TOXIC, EVEN THOUGH PURE CARBON IS NOT.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:DATA NOT AVAILABLE.
======================= First Aid Measures =======================
First Aid:SKIN:WASH THOROUGHLY WITH SOAP AND WATER. GET MD. EYES:FLUSH
THOROUGHLY WITH WATER FOR AT LEAST 15 MINUTES. GET MD. DUST
INHALATION:REMOVE TO FRESH AIR. GET MD. INGEST:IF CONSCIOUS, INDUCE
VOMITING. G ET MD.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, CO2, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . DANGER DUE TO SPONTANEOUS HEATING WHEN WET
OR TIGHTLY PACKED.
Unusual Fire/Explosion Hazard:MAY IGNITE AT TEMPERATURES ABOVE 300F IN
AMBIENT CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:TAKE UP AND CONTAINERIZE FOR PROPER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNR CLSD & AWAY FROM HEAT,
SPKS, OPEN FLAME & OXIDIZING AGENTS. AVOID WETTING & SUBSEQUENT
DRYING IN STORAGE. DO NOT BREATHE DUST.
Other Precautions:DO NOT GET IN EYES. AVOID PROLONGED OR REPEATED SKIN
CONTACT. DO NOT TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:MATERIAL SHOULD BE HANDLED OR TRANSFERRED IN APPROVED FUME
HOOD OR WITH ADEQUATE VENTILATION.
Other Protective Equipment:PROTECTIVE CLOTHING, EYE WASH & SAFETY
EQUIPMENT SHOULD BE READILY AVAILABLE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:7592F,4200C
Melt/Freeze Pt:M.P/F.P Text:6332F,3500C
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK, ODORLESS, AMORPHOUS POWDER OR GRANULES.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS.
Stability Condition to Avoid:AVOID DUSTING (DISPERSION OF FINE
PARTICLES IN AIR) AS DUST PARTICLES CAN FORM EXPLOSIVE MIXTURES
WITH AIR.
Hazardous Decomposition Products:COX
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE & LOCAL
REGULATIONS .
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: SPRAYMASTER PRO UNI-GRIP DRYFALL SPR 120 (SUPDAT)
Cage: IO491
=======================================================
Contractor Summary
=======================================================
Cage: 01PD6
Cage: IO491
=======================================================
Ingredients
=======================================================
Cas: 1317-65-3
RTECS #: EV9580000
% Wt: 5-10
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST
------------------------------
Cas: 1332-58-7
RTECS #: GF1670500
% Wt: 5-10
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 2 MG/M3 TDUST
------------------------------
Cas: 13463-67-7
RTECS #: XR2275000
% Wt: 5-10
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST
------------------------------
Cas: 7631-86-9
% Wt: 1-5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 50-00-0
RTECS #: LP8925000
% Wt: <0.1
OSHA PEL: SEE 1910.1048
ACGIH TLV: C 0.3 PPM, A2
EPA Rpt Qty: 100 LBS
DOT Rpt Qty: 100 LBS
------------------------------
Cas: 7732-18-5
RTECS #: ZC0110000
% Wt: 50-60
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 89678-90-0
(1-METHYLETHENYL)BENZENE, AMMONIUM SALT)
% Wt: 1-5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Cas: 25153-46-2
% Wt: 10-20
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
RTECS #: 9999999VO
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
-----------------------------
PERSIS, OBTAIN MED TREATMENT. INGEST: IF
-----------------------------
-----------------------------
-----------------------------
UNDER SPECIAL PROTECTION INFORMATION.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: ACUTE: INHAL: IRRIT OF RESP TRACT. PRLNGD INHAL MAY LEAD
TO MUCOUS MEMBRANE IRRIT, FATG, HDCH, NAUS, VOMIT, DIARR, COUGH, DFCLTY
W/SPEECH, RESP PROBLEMS, METALLIC TASTE, BRONCH, FEVER & CHILLS, DEHYDR
ATION, PNEUMOCONIOSIS. POSSIBLE SENSIT TO RESP TRACT. SKIN: IRRIT. POSS
SENSIT TO SKIN. EYE: IRRIT. (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: FORMALDEHYDE: IARC MONO, SUPP, VOL 7, PG 211,
1987: GROUP 2A. NTP 7TH ANNUAL RPT ON CARCINS, 1994: ANTIC TO BE (SUPDAT)
Signs And Symptions Of Overexposure: HLTH HAZ: PRLNGD/RPTD CONT CAN CAUSE
BLURRED VISION, TEARING OF EYES. INGEST: MAY CAUSE NAUS, GI DISTURB. SUPP
HLTH INFO: CONTAINS FORMALDEHYDE, POTNTL CANCER HAZARD. RATS EXPOSED TO
FORMALDEHYDE VIA INHAL DEVELOPED CANCER OF NASAL CAVITY.EVIDENCE IN HUMANS
IS LIMITED (NASAL & NASOPHARYNGEAL CANCER). (SUPDAT)
Medical Cond Aggravated By Exposure: EYE, SKIN, RESPIRATORY DISORDERS LUNG
DISORDERS ASTHMA-LIKE CONDITIONS.
First Aid: INHAL: REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
GET EMER MED ATTN. HAVE TRAINED PERSON GIVE OXYG IF NEC. GET MED HELP FOR ANY
BRTHG DFCLTY. REMOVE TO FRESH AIR IF INHAL CAUSE EYE WATERI NG, HDCH,
DIZZ/OTHER DISCOMFORT. SKIN: FLUSH W/WATER. THEN WASH THORO W/SOAP &
WATER. REMOVE CONTAMD CLTHG. WASH CONTAMD CLTHG BEFORE RE-USE. EYE: FLUSH
IMMED W/LG AMTS OF WATER, ESPECIALLY
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: COMPLY W/ALL APPLIC HLTH & ENVIRONMENTAL REGS.
ELIM ALL SOURCES OF IGNIT. VENTILATE AREA. EVACUATE ALL UNNEC PERS. PLACE
COLLECTED MATL IN PROPER CNTNR. COMPLETE PERSONAL PROT EQUIP MUST BE USED
DURIN G CLEANUP. SM SPILLS-USE ABSORB TO PICK
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH ALL APPLICABLE FEDERAL,
STATE & LOCAL REGS. AVOID DISCHARGE TO NATURAL WATERS.
Handling And Storage Precautions: STORE <100F. KEEP FROM FREEZING. USE ONLY
W/ADEQ VENT. DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
Other Precautions: AVOID CONT W/SKIN & EYES, & BRTHG OF VAPS. KEEP
CNTNRS TIGHTLY CLSD & UPRIGHT WHEN NOT IN USE. AVOID CNDTNS WHICH RSLT IN
FORMATION OF INHALABLE PARTICLES SUCH AS SPRAYING/ABRADING (SANDING) PAINTED
S URFS. IF SUCH CNDTNS CANNOT BE
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONE
Extinguishing Media: DRY CHEMICAL OR FOAM WATER FOG. CARBON DIOXIDE.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). WATER MAY BE USED TO COOL AND PROTECT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard: CLSD CNTNRS MAY BURST IF EXPOSED TO EXTREME
HEAT/FIRE. MAY DECOMPOSE UNDER FIRE CNDTNS EMITTING IRRITANT AND/OR TOXIC
GASES. IN CLSD TANKS, WATER/FOAM (SUPDAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: CTL ENVIRONMENTAL CONCS BELOW APPLIC STDS. WHERE RESP
PROT IS REQD, USE ONLY NIOSH APPRVD RESPIRATORS I/A/W OSHA STD 29 CFR
1910.134.
Ventilation: PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT BUILD-UP
OF VAPORS.
Other Protective Equipment: ANSI APPRVD EYE WASH & DELUGE SHOWER (FP N).
IMPERVIOUS CLOTHING.
Work Hygienic Practices: WASH HANDS THORO AFTER HNDLG, ESPECIALLY BEFORE
EATING/SMOKING.
Supplemental Safety and Health: MFR TRADE NAME/PART NO: EGG SHELL WHITE. EXPLO
HAZ: MAY CAUSE FROTHING/ERUPTION. EXPLAN OF CARCIN: CARCIN. ANIMAL: NASAL
TUMORS. EFTS OF OVEREXP: FORMALDEHYDE IS LISTED AS CARCIN BY OSHA, PROBABLE
HUM AN CARCIN (GROUP 2A) BY IARC, & ANTIC HUMAN CARCIN BY NTP. OVEREXP
CAN CAUSE EYE, SKIN, & RESP TRACT IRRIT,
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 212F,100C
Spec Gravity: 1.27 (FP N)
Evaporation Rate & Reference: NOT KNOWN
Solubility in Water: NOT KNOWN
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume: 64.36
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: ELEVATED TEMPERATURES, CONT W/OXIDIZING AGENT,
CONT W/ALUMINUM OR ZINC, FREEZING, SPARKS, OPEN FLAME.
Materials To Avoid: OXIDIZERS, ACIDS, ALUMINUM, ZINC, MAGNESIUM, SODIUM,
POTASSIUM.
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE, OXYGEN,
TOXIC GASES.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: SPRAYMASTER PRO UNI-GRIP DRYFALL SPR 120 (SUPDAT)
Cage: IO491
Assigned IND: Y
Company Name: ICI PAINTS
Street: 925 EUCLID AVE
Zipcode: 44115
Label Required IND: Y
Date Of Label Review: 02/02/1998
Status Code: C
Label Date: 02/02/1998
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: INHAL: IRRITATION OF RESPIRATORY TRACT.
PROLONGED INHALATION MAY LEAD TO MUCOUS MEMBRANE IRRITATION, FATIGUE,
HEADACHE, NAUSEA, VOMITING, DIARRHEA, COUGHING, DFCLTY W/SPEECH, RESPIRATORY
PROBLE MS, METALLIC TASTE, BRONCH, FEVER & CHILLS, DEHYDRATION,
PNEUMOCONIOSIS. SKIN: IRRITATION. EYE: IRRITATION, BLURRED VISION, TEARING.
INGEST: NAUSEA, GASTROINTESTINAL DISTURBANCES. CHRONIC: CANCER HAZA RD.
CONTAINS FORMALDEHYDE, WHICH IS LISTED AS AN ANIMAL NASAL CARCINOGEN (FP N).
SKIN: SENSITIZATION. INHAL: SENSITIZATION TO RESPIRATORY TRACT.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:GILLESPIE BRASS REFURBISHER
CAGE:IO912
CAGE:91522
CAGE:IO912
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ETHYL KETONE (SARA 313) (CERCLA)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 60-65%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM/300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPANOL (SARA 313)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 5-10%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM/500 STEL
Ingred Name:AMMONIUM HYDROXIDE (SOLUTION) (CERCLA) CONTAINING INGS 4 &
5
CAS:1336-21-6
RTECS #:BQ9625000
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:AMMONIA (SARA 302/313) (CERCLA)
CAS:7664-41-7
RTECS #:BO0875000
Fraction by Wt: 25-30%
OSHA PEL:50 PPM
ACGIH TLV:25 PPM/35 STEL
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:ALUMINUM OXIDE (SARA 313)
CAS:1344-28-1
RTECS #:BD1200000
Fraction by Wt: 15-20%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:MAX VOLATILE ORGANIC COMPOUND: 628 GRAMS PER
LITER(EXCLUDING EXEMPT SOLVENTS & WATER). MAX VAP PRESS (OF VOC):
46 @ 20C.
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT: GOLD, SILVER, ALLOYS OF THESE METALS, ACIDS, AND
STRONG OXIDIZING AGENTS.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP: ESOPHAGUS, STOM, MOUTH & THROAT; IRRIT TO
STOM; ABDOM PAIN; REDDENING OF FACE; COLLAPSE; UNCON; (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: & DEATH. CHRONIC: RPTS HAVE ASSOC RPTD & PRLNGD
OVEREXP TO SOLVS W/NEUROLOGICAL & OTHER PHYSIOLOGICAL (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: DMG. MAY CAUSE WEAK, FATG, DFCLTY BRTHG, & NUMBNESS
IN HANDS & FEET.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: CALL YOUR LOCAL POISON CONTROL CENTER FOR
FURTHER INFORMATION.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: NONCOMBUST ABSORB MATL & PLACE IN PLASTIC CNTNR
WHERE APPLIC. LG SPILLS: DIKE FAR AHEAD OF SPILL (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: FOR LATER DISP.
RTECS #:9999999ZZ
Ingred Name:RESP PROT: PROPERLY FITTED NIOSH APPRVD RESP FOR ORGANIC
SOLV VAPS. DUST MASK DOES NOT PROVIDE PROT AGAINST VAPORS.
RTECS #:9999999ZZ
Ingred Name:VENT: AIR ACROSS WORK AREA. IF STRONG ODOR IS NOTICED/YOU
EXPERIENCE SLIGHT DIZZ, HDCH, NAUS/EYE-WATERING - (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: STOP - VENTILATION IS INADEQUATE. LEAVE AREA
IMMEDIATELY.
RTECS #:9999999ZZ
REMOVE CLTHG THAT BECOMES SOILED WITH PRODUCT.
RTECS #:9999999ZZ
Ingred Name:HYGIENE PRACT: THAT HAS BEEN CONTAMD BY PRIOR USE. DISCARD
ANY CLTHG/OTHER PROT EQUIP THAT CANNOT BE DECONTAMD, (ING 19)
RTECS #:9999999ZZ
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: VAP HARMFUL. MAY CAUSE
HDCH; NAUS; COUGH; IRRIT TO THROAT & RESP TRACT; NUMBNESS IN
FINGERS, ARMS & LEGS; DFCLTY BRTHG; CHEST PAINS; BRONCH;
BRONCHOSPASM; INJURIES TO MUC MEMBS; CHEM PNE UM; PULM EDEMA;
TISSUE DMG; & DEATH. SKIN: IRRITANT. LIQUID IS ABSORBED READILY
THRU SKIN. MAY CAUSE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: NUMBNESS IN FINGERS & ARMS; IRRIT;
BLISTERS; BURNS; & TISS DESTRUCTION. VAPS & MIST MAY IRRITATE MOIST
SKIN. EYE: IRRITANT. MAY CAUSE IRRIT & PAIN; CORNEAL ULCERATIONS OF
EYE; & BLNDNESS. VA PS/MIST CAN IRRITATE EYES. INGEST: MAY BE CORR
TO MOUTH & THROAT. MAY CAUSE NAUS; VOMIT; GI IRRIT; BURNING OF (ING
8)
Medical Cond Aggravated by Exposure:DISEASES OF THE EYE AND PULMONARY
SYSTEM.
======================= First Aid Measures =======================
First Aid:INHAL: MOVE TO AIR FREE OF VAPORS. ADMIN OXYGEN/ARTF RESP
UNTIL MED ASSISTANCE CAN BE RENDERED. SKIN: WASH W/SOAP & LG QTYS
OF WATER & SEEK MED ATTN IF IRRIT FROM CONT PERSISTS. EYE: FLUSH
W/LG QTYS O F WATER FOR AT LST 15 MINS & SEEK IMMEDMED ATTN.
INGEST: CALL YOUR POIS CTL CTR, HOSPITAL EMER ROOM/PHYS IMMED FOR
INSTRUCTIONS. NOTE TO PHYS: THIS FORMULA IS REGISTERED WITH
POISINDEX. (ING 11)
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:23.0F,-5.0C
Extinguishing Media:USE CARBON DIOXIDE, DRY POWDER, OR FOAM.
Fire Fighting Procedures:NIOSH APPRVD SCBA & FULL PROT EQUIP . STOR
CNTNRS EXPOS TO FIRE SHOULD BE KEPT COOL W/WATER SPRAY TO PVNT
PRESS BUILD-UP. STAY AWAY FROM HEADS OF (SUPDAT)
Unusual Fire/Explosion Hazard:DANGER! FLAMM. KEEP AWAY FROM HEAT,
SPARKS, FLAME, & ALL OTHER SOURCES OF IGNITION. DO NOT SMOKE.
EXTING ALL FLAMES & PILOT LIGHTS, & TURN OFF STOVES, (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP UNNEC PEOPLE AWAY; ISOLATE HAZ AREA &
DENY ENTRY. STAY UPWIND, OUT OF LOW AREAS, & VENTILATE CLSD SPACES
BEFORE ENTERING. SHUT OFF IGNIT SOURCES; KEEP FLARES, SMKNG/FLAMES
OUT OF HAZ AREA. SM SPI LLS: TAKE UP LIQ W/SAND, EARTH OR OTHER(ING
12)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNR TIGHTLY CLSD WHEN NOT IN
USE. STORE IN COOL, DRY PLACE. DO NOT STORE NEAR FLAMES/AT ELEVATED
TEMPS. DO NOT REUSE THIS CONTAINER.
Other Precautions:READ CAREFULLY ALL CAUTIONS & DIRECTIONS ON PROD
LABEL BEFORE USE. SINCE EMPTY CNTNR RETAINS RESIDUE, FOLLOW ALL
LABEL WARNINGS EVEN AFTER CNTNR IS EMPTY. DISPOSE OF EMPTY CNTNR
ACCORDING TO ALL REGUL ATIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR OSHA CONTROLLED WORK PLACE & OTHER REGULAR
USERS - USE ONLY W/ADEQ VENT UNDER ENGINEERED AIR CTL SYS DESIGNED
TO PVNT EXCEEDING APPROP TLV. FOR OCCASNL USE, WHERE ENGINEERED AIR
CTL IS NOT FEASIBL E, USE PROPERLY MAINTAINED & (ING 14)
Ventilation:USE ONLY W/ADEQ VENT TO PVNT BUILD-UP OF VAPS. OPEN ALL
WINDOWS & DOORS. USE ONLY W/CROSS VENT OF MOVING FRESH (ING 15)
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
IMPERMEABLE APRONS, ETC.
Work Hygienic Practices:DO NOT EAT, DRINK/SMOKE IN WORK AREA. WASH
HANDS THORO AFTER USE. BEFORE REUSE, THORO CLEAN ANY CLTHG/PROT
EQUIP(ING 18)
Supplemental Safety and Health
% VOLAT: 76.98 BY WT. FIRE FIGHT PROC: CNTNRS THAT HAVE BEEN EXPOSED TO
INTENSE HEAT/FLAME. EXPLO HAZ: HEATERS, ELEC MOTORS & ALL OTHER
SOURCES OF IGNIT DURING USE & UNTIL ALL VAPS ARE GONE. BEWARE OF
STATIC ELECTRICITY THAT MAY BE GENERATED BY SYNTHETIC CLTHG & OTHER
SOURCES. MATL TO AVOID: METAL, ZINC, (ING 7)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>175F,>79C
Vapor Density:HVR/AIR
Spec Gravity:0.94
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NOT KNOWN
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPAT W/CAUSTICS, AMINES, ALKANOLAMINES, ALDEHYDES, AMMONIA,
CHLORINATED CMPDS, COPPER, ALUMINUM, GALVANIZED(SUPDAT)
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:DECOMPOSITION MAY PRODUCE NITROUS
OXIDES, AND AMMONIA VAPORS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH APPLICABLE LOCAL,
STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:C=0954, NATURAL ORANGE LOTION HAND CLEANER (SUPDAT)
CAGE:GO199
CAGE:GO199
CAGE:02905
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: <60%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CYCLOHEXENE, 1-METHYL-4-(1-METHYLETHENYL)-, (R)-;
(D-LIMONENE)
CAS:5989-27-5
RTECS #:GW6360000
Fraction by Wt: <13%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PUMICE
CAS:1332-09-8
Fraction by Wt: <10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ALKOXYLATED FATTY ALCOHOL; (LINEAR ALCOHOL ALKOXYLATE)
CAS:69227-21-0
Fraction by Wt: <10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VEGETABLE OIL
CAS:68956-68-3
RTECS #:YX1850000
Fraction by Wt: <7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DIPENTENE (MFR'S INVALID CAS NO:138-96-8)
CAS:138-86-3
RTECS #:OS8100000
Fraction by Wt: <7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ALOE, PHARMACEUTICAL; (ALOE EXTRACT) (MFR'S CAS
NO:8001-97-6)
CAS:8001-97-6
RTECS #:BC8055000
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL, WHITE; (BABY OIL)
CAS:8042-47-5
RTECS #:PY8047000
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:JAJOBA OIL; (JOJOBA OIL)
CAS:61789-91-1
RTECS #:NY9262700
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:LANOLIN
CAS:8006-54-0
RTECS #:OE3201000
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:4-ISOTHIOAZOLIN-3-ONE, 5-CHLORO-2-METHYL-; (KATHON)
CAS:26172-55-4
RTECS #:NX8156850
Fraction by Wt: TRACE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHANOL, 2,2',2"-NITRILOTRI-; (TRIETHANOLAMINE)
CAS:102-71-6
RTECS #:KL9275000
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:5 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT) >10 GM/KG.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE EYE IRRITATION. NO ACUTE
TOXIC EFFECTS EXPECTED BY INHALATION, INGESTION OR CONTACT DURING
ANTICIPATED HANDLING AND USAGE. CHRONIC:NO LONG TERM EFFECTS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD . EYES:FLUSH
IMMEDIATELY & THOROUGHLY W/WATER FOR AT LEAST 15 MINUTES. IF
CONDITION WORSENS OR IRRITATION PERSISTS, CONTACT MD. INGEST:DO NOT
INDUCE VOMITING. IF VOMITING OCCURS, LOWER PERSON'S HEAD BELOW
THEIR KNEES TO AVOID ASPIRATION. CONTACT MD OR POISON CONTROL CTR.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Extinguishing Media:WATER FOG, ALCOHOL FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP LG SPILLS/ABSORB ON INERT MATL.
COLLECT IN SEALED APPRVD CNTNR FOR DISP. FLUSH AREA W/WATER TO
CLEAN UP SM AMTS & REDUCE POSS SLIPPERY FLOOR HAZ. NOT EXPECTED TO
CAUSE ADVERSE ENVIRON EFTS. NO T CONSIDERED ENVIRONMENTALLY HARMFUL
FROM (SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM REACH OF SMALL
CHILDREN. AVOID CONTACT W/EYES. DO NOT TAKE INTERNALLY. STORE AT
AMBIENT INDOOR CONDITIONS. KEEP CONTAINERS SEALED.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NOT REQUIRED IF USED AS DIRECTED.
Ventilation:MECHANICAL:NOT REQUIRED IF USED AS DIRECTED; LOCAL:NOT
REQUIRED.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:ROUTINE PERSONAL HYGIENE.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:WITH PUMICE. PH:6-7 (UNDILUTED). SPILL
PROC:NORMAL DILUTION. EXPECTED USAGE & TYPICAL DRAINAGE TO SEWERS,
SEPTIC SYSTEMS & TREATMENT PLANTS. BIODEGRADATION: YES, IN NORMAL
WAS TE STREAMS.
================== Physical/Chemical Properties ==================
Spec Gravity:1.02 (H*2O=1)
pH:SUPDAT
Evaporation Rate & Reference:0.7 (H*2O=1)
Solubility in Water:80%
Appearance and Odor:CREAMY OPAQUE VISCOUS GEL; ORANGE FRAGRANCE.
Percent Volatiles by Volume:<70
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:COMBUSTION MAY PRODUCE CO, CO*2, NO*X.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE ACCORDING TO LOCAL, STATE/PROVINCE,
FEDERAL & INTERNATIONAL REGULATIONS. NOT A CHARACTERISTIC HAZARDOUS
OR LISTED WASTE BY EPA & RCRA (4O CFR PART 261).
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FPC2083 EPOCAST 1614
Preparer's Name:RAJESH S PATEL
CAGE:GO486
CAGE:GO486
POLYMERS
CAGE:99384
============= Composition/Information on Ingredients =============
Ingred Name:QUATERNARY AMMONIUM COMPOUNDS, BENZYL(HYDROGENATED TALLOW A
KYL)DIMETHYL, CHLORIDES, COMPDS. W/HECTORITE; CLAY
CAS:71011-26-2
Ingred Name:ANTIMONY TRIOXIDE, ANTIMONY OXIDE (SUSP CARCINOGEN BY
ACGIH, ANIMAL CARCINOGEN IARC - GROUP 2B)*97-2*
CAS:1309-64-4
RTECS #:CC5650000
ACGIH TLV:0.5 MG/CUM (A2)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOLATILE ORGANIC CONTENT: 10 GM/L
RTECS #:9999999VO
Ingred Name:GLASS OXIDE, FIBER GLASS WOOL, LEAD BOROSILICATE GLASS
ENAMEL FLUX
CAS:65997-17-3
Ingred Name:3,4-EPOXY CYCLOHEXYL METHYL-3,4-CYCLOHEXYL CARBOXYLATE
*97-2*
CAS:2386-87-0
RTECS #:RN7750000
Ingred Name:1,3-ISOBENZOFURANDIONE, TETRAHYDRO-5-METHYL-
CAS:34090-76-1
Ingred Name:3,3',4,4'-BENZOPHENONETETRACARBOXYLIC ACID DIANHYDRIDE
CAS:2421-28-5
Ingred Name:2,2-BIS(4-(2,3-EPOXYPROPYLOXY)PHENYL)PROPANE, BISPHENOL A
DIGLYCIDYL ETHER, EPON 828, EPOXIDE A
CAS:1675-54-3
RTECS #:TX3800000
Ingred Name:PENTABROMODIPHENYL OXIDE
CAS:32534-81-9
Ingred Name:1,3-ISOBENZOFURANDIONE,3A,4,7,7A-TETRAHYDRO *97-2*
CAS:85-43-8
RTECS #:GW5775000
Ingred Name:PHENOL, POLYMER WITH FORMALDEHYDE, GLYCIDYL ETHER *97-2*
CAS:28064-14-4
Ingred Name:REACTION PRODUCTS OF EPICHLOROHYDRIN & BISPHENOL A
*97-2*
CAS:25085-99-8
Ingred Name:GLYCIDOXYPROPYLTRIMETHOXYSILANE, SILANE,
3-(2,3-EPOXYPROPOXY) PROPYLTRIMETHOXY-
CAS:2530-83-8
RTECS #:VV4025000
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RATS): 2140-34600 GM/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: CAN IRRITATE NOSE &
THROAT. EYES: SEVERE IRRITANT, POSSIBLE INJURY. SKIN: SEVERE
IRRITANT; HARMFUL IF ABSORBED. INGESTION: SUBSTANCE WILL CAUSE
BURNING. PROLONGED/REPEATED EXPOSURE MAY CAU SE DELAYED & SERIOUS
INJURY. CAN CAUSE ALLERGIC REACTION & DAMAGE TO LIVER, LUNGS &
THYROID.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, BURNING & SWELLING OF MOUTH, THROAT
& ABDOMEN.
Medical Cond Aggravated by Exposure:ECZEMA, SKIN, ALLERGY/RESPIRATORY
DISEASE CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE TO FRESH AIR. GIVE OXYGEN IF NECESSARY.
EYES: FLUSH W/LARGE AMOUNTS OF WATER FOR 15 MINS. SKIN: WASH
THOROUGHLY W/SOAP & WATER. INGESTION: DILUTE BY GIVING 2 GLASSES OF
WATER TO DRINK . NEVER GIVE ANYTHING BY MOUTH IF UNCONSCIOUS.
OBTAIN MEDICAL ATTENTION IN ALL CASES. NOTE TO PHYSICIAN: ALLERGIC
DERMATITIS/RESPIRATORY RESPONSE IN SOME INDIVIDUALS MAY BE DELAYED
BY WEEKS/MONTHS.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>244.4F
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER
Fire Fighting Procedures:WEAR BREATHING APPARATUS (MSHA/NIOSH APPROVED,
PRESSURE DEMAND, SELF CONTAINED) & FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:DECOMPOSITION & COMBUSTION PRODUCTS MAY
BE TOXIC.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROTECTIVE EQUIPMENT. CLEAN ALL TRACES OF
LEAK. SHOVEL INTO DRY, CLEAN CONTAINERS. ON HARD SURFACE, USE
ABSORBENT TO PICK UP REMAINDER; ON LOOSE SURFACE SHOVEL UP
CONTAMINATED LAYER. KEEP RUNOFFS OUT OF SEWERS & OPEN BODIES OF
WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:MAXIMUM STORAGE TEMPERATURE: 95F.
STORE AWAY FROM EXCESSIVE HEAT, REACTIVE MATERIALS & OTHER IGNITION
SOURCES. DON'T STORE NEAR FOOD/FEED.
Other Precautions:CORROSIVE TO COPPER & BRASS ON LONG TERM STORAGE.
AVOID EYE & SKIN CONTACT. READ TECHNICAL DATA SHEET BEFORE HANDLING
PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR RESPIRATOR (MSHA/NIOSH) SUITABLE FOR
CONCENTRATIONS & TYPES OF AIR CONTAMINANTS ENCOUNTERED.
Ventilation:MECHANICAL LOCAL EXHAUST VENTILATION AT POINT OF
CONTAMINANT RELEASE.
Other Protective Equipment:PROTECTIVE CLOTHING, SAFETY SHOWER, EYEWASH
FACILITY.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Pres:<1
Vapor Density:>1
Spec Gravity:0.75
Evaporation Rate & Reference:(BU ACETATE =1): <1
Solubility in Water:REACTS W/WATER
Appearance and Odor:TAN COLOR SOFT PASTE W/SLIGHT ODOR
Percent Volatiles by Volume:1/WT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, AMINES, ALKALI METAL IONS, STRONG OXIDIZING AGENTS
Stability Condition to Avoid:ELEVATED TEMPERATURES, HEAT
Hazardous Decomposition Products:CO, CO2, ALDEHYDES & HYDROGEN BROMIDE
Conditions to Avoid Polymerization:HEAT, ACIDS, AMINES & ALKALI METAL
IONS
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN APPROVED EQUIPMENT.
LANDFILL/INCINERATE CONTAMINATED MATERIAL IN ACCORDANCE W/LOCAL,
STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DUNCAN GL 600 SERIES
CAGE:21546
CAGE:21546
============= Composition/Information on Ingredients =============
Ingred Name:LEAD OXIDE YELLOW, LEAD OXIDE *96-2*
CAS:1317-36-8
RTECS #:OG1750000
OSHA PEL:0.5 MG
ACGIH TLV:0.15 MG/CUM
Ingred Name:BARIUM OXIDE
CAS:1304-28-5
RTECS #:CQ9800000
OSHA PEL:0.5 MG/CUM
ACGIH TLV:0.5 MG/CUM
Ingred Name:ALKALI BOROSILICATE FRITS *96-2*
CAS:65997-18-4
Ingred Name:CRYSTALLINE-QUARTZ SILICA, SILICA DUST (SUSPECTED HUMAN
CARCINOGEN BY IARC-GROUP 2A; SUSPECTED CARCINOGEN NTP) *96-2*
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <8%
Other REC Limits:0.05 MG/CUM (NIOSH)
OSHA PEL:10 MG/CUM %RESP SIO2
ACGIH TLV:0.1 MG/CUM RESP DUST
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:OVEREXPOSURE TO LEAD MAY CAUSE NERVOUS
SYSTEM, KIDNEY/BONE MARROW DAMAGE/HARM TO THE DEVELOPING FETUS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:WEIGHT LOSS, STOMACHE CRAMPS, LOSS OF
COORDINATION, JOINT & MUSCLE PAINS.
Medical Cond Aggravated by Exposure:ABRASIVE, CAN SCRATCH EYES.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER AT LEAST 15 MINS. SKIN: WASH W/SOAP &
WATER. SKIN: WASH W/SOAP & WATER. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:NONE. WILL NOT BURN.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP PROPERLY W/PAPER TOWELS & A WET
SPONGE.
======================Handling and Storage ======================
Handling and Storage Precautions:WHEN USING, DON'T EAT, DRINK/SMOKE.
WASH HANDS IMMEDIATELY AFTER USE. KEEP SEALED. KEEP OUT OF REACH OF
CHILDREN.
Other Precautions:AVOID USING IF PREGNANT/CONTEMPLATING PREGNANCY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED DUST & MIST RESPIRATOR.
Ventilation:LOCAL EXHAUST: RECOMMENDED. MECHANICAL(GENERAL):
RECOMMENDED WHEN SPRAYING. SPECIAL: USE RESPIRATOR WHEN SPRAYING.
Other Protective Equipment:IF IN THE GLAZE FORM & APPLYING BY SPRAY,
USE SPRAY BOOTH & RESPIRATORY. CLEAN SPRAY BOOTH FILTERS OFTEN.
Work Hygienic Practices:WEAR PROTECTIVE CLOTHING THAT IS REMOVED BEFORE
EATING, DRINKING, SMOKING/LEAVINGWORK. (SEE SUPP)
Supplemental Safety and Health
WORK HYGIENIC PRACTICES CONT'D: WASH THOROUGHLY, IMMEDIATELY AFTER
SPRAYING. IF GLAZE SPRAYING, REGULAR BLOOD LEADLEVEL TESTING IS
ADVISEABLE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Melt/Freeze Pt:M.P/F.P Text:1800F
Spec Gravity:1.7
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORED LIQUID W/NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SULFURIC ACID 52-100%, 5030
CAGE:HO851
CAGE:HO851
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:OTHER PREC: TOOLS BECAUSE OF POSS OF HYDROGEN GAS BEING
PRESENT. CONTRS MAY BE HAZ WHEN EMPTY SINCE THEY RETAIN (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: PRODUCT RESIDUES (VAPORS, LIQUID); OBSERVE ALL
WARNINGS AND PRECAUTIONS LISTED FOR THE PRODUCT.
RTECS #:9999999ZZ
Ingred Name:RESP PROT: FOR EMER/INSTANCES WHERE EXPOS LEVELS ARE NOT
KNOWN, USE NIOSH APPRVD FULL-FACEPIECE POS-PRESS, AIR- (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: SUPPLIED RESPIRATOR. WARNING: AIR PURIFYING
RESPIRATORS DO NOT PROTECT WORKERS IN OXYGEN-DEFICIENT ATMOSPHERES.
RTECS #:9999999ZZ
Ingred Name:VENT: IT CAN CONTROL EMISSIONS OF CONTAMINANT AT ITS
SOURCE, PREVENTING DISPERSION OF IT INTO GEN WORK AREA. (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20: PLEASE REFER TO ACGIH DOCUMENT, "INDUSTRIAL VENT, A
MANUAL OF REC PRACTICES", MOST RECENT EDITION, FOR DETAILS.
RTECS #:9999999ZZ
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH: MAY DIFFER FROM FED DISPOSAL REGS. DISPOSE
OF CONTR & UNUSED PROD I/A/W FED, STATE & LOC REQUIREMENTS.
RTECS #:9999999ZZ
Ingred Name:SULFURIC ACID (SARA 302/313) (CERCLA)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 52-100%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3/3 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 0-48%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MATLS TO AVOID: HALOGENS, METAL ACETYLIDES, OXIDES &
HYDRIDES, METALS (YIELDS HYDROGEN GAS), STRONG OXIDIZING & (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3: REDUCING AGENTS AND MANY OTHER REACTIVE SUBSTANCES.
RTECS #:9999999ZZ
Ingred Name:HAZ DECOMP PROD: REACTS W/CARBONATES TO GENERATE CARBON
DIOXIDE GAS, & W/CYANIDES & SULFIDES TO FORM POISONOUS (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: HYDROGEN CYANIDE AND HYDROGEN SULFIDE RESPECTIVELY.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP: CONT/INGEST. CIRCULATORY SHOCK IS OFTEN
IMMED CAUSE OF DEATH. EYES: CORR. CAN CAUSE BLURRED (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: VISION, REDNESS, PAIN & SEV TISS BURNS. CAN CAUSE
BLINDNESS. CHRONIC: LONG-TERM EXPOS TO MIST/VAPS MAY (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: CAUSE DAMAGE TO TEETH. CHRONIC EXPOSURE TO MISTS
CONTAINING SULFURIC ACID IS A CANCER HAZARD.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: OF BICARBONATE OF SODA. CALL MD IMMED.
EYES: IMMED FLUSH W/GENTLE BUT LGE STREAM OF WATER FOR (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: AT LEAST 15 MINUTES, LIFTING LOWER AND UPPER
EYELIDS OCCASIONALLY. CALL MD IMMEDIATELY.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: WASTE CONTR. DO NOT USE COMBUST MATLS, SUCH AS
SAWDUST. DO NOT FLUSH TO SEWER! US REGS (CERCLA) REQ (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: REPORTING SPILLS & RELEASES TO SOIL, WATER & AIR IN
EXCESS OF REPORTABLE QTYS. TOLL FREE NUMBER FOR THE (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: U.S. COAST GUARD NATIONAL RESPONSE CENTER IS (800)
424-8802.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT): 2140 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: DAMAGING EFTS ON MUC
MEMBS & UPPER RESP TRACT. SYMPS MAY INCL IRRIT OF NOSE & THROAT &
LABORED BRTHG. MAY CAUSE LUNG EDEMA, A MED EMER. INGEST: CORR.
SWALLOWING CAN CAUSE SEV BURNS OF MO UTH, THROAT & STOM, LEADING TO
DEATH. CAN CAUSE SORE THROAT, VOMIT, DIARR. CIRCULATORY COLLAPSE
WITH (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SULFURIC ACID: IARC MONOGRAPHS, VOLUME
54, PAGE 41, 1992: GROUP 1. ANIMAL: PULMONARY IRRITATION.
Effects of Overexposure:HLTH HAZ: CLAMMY SKIN, WEAK & RAPID PULSE,
SHALLOW RESPS & SCANTY URINE MAY FOLLOW INGEST/SKIN CONT.
CIRCULATORY SHOCK IS OFTEN IMMED CAUSE OF DEATH. SKIN: CORR. SYMPS
OF REDNESS, PAIN & SEV BURNS CAN OCCUR. CIRCULATORY COLLAPSE
W/CLAMMY SKIN, WEAK & RAPID PULSE, SHALLOW RESPS & SCANTY URINE MAY
FOLLOW SKIN (ING 7)
Medical Cond Aggravated by Exposure:PERSONS WITH PREEXISTING SKIN
DISORDERS OR EYE PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION MAY BE
MORE SUSCEPTIBLE TO THE EFFECTS OF THE SUBSTANCE.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTF RESP. IF
BRTHG IS DFCLT, GIVE OXYGEN. CALL MD IMMED. INGEST: DO NOT INDUCE
VOMIT. GIVE LGE QTYS OF WATER. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCON P ERSON. CALL MD IMMED. SKIN: IMMED FLUSHW/PLENTY OF WATER
FOR AT LEAST 15 MIN WHILE REMOVING CONTAM CLTHG & SHOES. WASH CLTHG
BEFORE REUSE. EXCESS ACID ON SKIN CAN BE NEUTRALIZED W/A 2% SOLN
(ING 10)
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEM, FOAM/CARBON DIOXIDE. DO NOT USE WATER.
HOWEVER, WATER SPRAY MAY BE USED TO KEEP FIRE-EXPOSED CONTRS COOL.
Fire Fighting Procedures:WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP .
STRUCTURAL FIREFIGHTER'S PROT CLTHG IS INEFFECTIVE FOR FIRES
INVOLVING THIS MATL. STAY AWAY FROM SEALED CONTRS.
Unusual Fire/Explosion Hazard:CONC MATL IS A STRONG DEHYDRATING AGENT.
REACTS W/ORG MATLS & MAY CAUSE IGNIT OF FINELY-DIVIDED MATLS ON
CONT. CONT W/MOST METALS CAUSES FORM OF FLAM (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA. WEAR APPROP PERS PROT EQUIP.
ISOLATE HAZ AREA. KEEP UNNEC & UNPROT PERS FROM ENTERING. CONTAIN &
RECOVER LIQ WHEN POSS. NEUT W/ALKALINE MATL (SODA ASH, LIME), THEN
ABSORB W/INERT MATL (VERM ICULITE, DRY SAND, EARTH), & PLACE IN
CHEM(ING 12)
Neutralizing Agent:J.T. BAKER NEUTRASORB OR TEAM 'LOW NA+' ACID
NEUTRALIZERS ARE RECOMMENDED.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL-VENTILATED
STORAGE AREA WITH ACID RESISTANT FLOORS AND GOOD DRAINAGE. PROTECT
FROM PHYSICAL DAMAGE.
Other Precautions:KEEP OUT OF DIRECT SUNLIGHT & AWAY FROM HEAT, WATER &
INCOMPATIBLE MATLS. DO NOT WASH OUT CONTR & USE IT FOR OTHER
PURPOSES. WHEN DILUTING, ALWAYS ADD ACID TO WATER; NEVER ADD WATER
TO ACID. WHEN OPEN ING METAL CONTRS, USE NON-SPKG (ING 16)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOS LIM IS EXCEEDED, NIOSH APPRVD FULL
FACEPIECE RESP W/ACID GAS CARTRIDGE & DUST/MIST FILTER MAY BE WORN
UP TO 50 TIMES EXPOS LIM/MAX USE CONC SPECIFIED BY APPROP
REGULATORY AGENCY/RESP SUPPLIER , WHICHEVER IS LOWEST. (ING 18)
Ventilation:SYS OF LOC &/OR GEN EXHST IS REC TO KEEP EXPOS BELOW
AIRBORNE EXPOS LIMS. LOC EXHST VENT IS GEN PREF BECAUSE (ING 20)
Other Protective Equipment:ANSI APPROVED EMER EYEWASH & DELUGE SHOWER .
IMPERVIOUS PROT CLOTHING INCLUDING BOOTS, LAB COAT,
APRON/COVERALLS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
BP: 554F (290C); DECOMPOSES AT 644F (340C). SPEC GRAV: 1.84 (98%), 1.40
(50%), 1.07 (10%). MP: 37.4F (3C) (100%), 89.6F (32C) (93%), 100F
(38C) (78%), 147F (64C) (65%). PH: 1 N SOLN (5% W/W)=0.3; 0.1 N
SOLN (0.5% W/W)=1.2; 0.01 N SOLN (0.05% W/W)=2.1. SOL IN WATER:
LIBERATES MUCH HEAT. EXPLO HAZ: & EXPLO HYDROGEN GAS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:SUP DAT
Melt/Freeze Pt:M.P/F.P Text:SUP DAT
Vapor Pres:1 @ 295F
Vapor Density:3.4
Spec Gravity:SUP DAT
pH:SUPDAT
Solubility in Water:MISCIBLE; (SUP DAT)
Appearance and Odor:CLEAR OILY LIQUID; ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, POTASSIUM CHLORATE, POTASSIUM PERCHLORATE, POTASSIUM
PERMANGANATE, SODIUM, LITHIUM, BASES, ORG MATL, (ING 3)
Stability Condition to Avoid:HEAT, MOISTURE, INCOMPATIBLES.
CONCENTRATED SOLUTIONS REACT VIOLENTLY WITH WATER, SPATTERING AND
LIBERATING HEAT.
Hazardous Decomposition Products:TOX FUMES OF OXIDES OF SULFUR WHEN
HEATED TO DECOMP. WILL REACT W/WATER/STEAM TO PRODUCE TOX &
CORROSIVE FUMES. (ING 5)
==================== Disposal Considerations ====================
Waste Disposal Methods:WHATEVER CANNOT BE SAVED FOR RECOVERY/RECYCLING
SHOULD BE HANDLED AS HAZ WASTE & SENT TO RCRA APPRVD INCIN/DISPOSED
IN RCRA APPRVD WASTE FACILITY. PROCESSING, USE/CONTAM OF THIS PROD
MAY CHANGE WASTE MANAGEMENT OPTIONS. STATE & LOC DISP REGS (ING
15)
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BLACK TONER FOR DC-4086
Kit Part:Y
CAGE:0AH08
CAGE:0AH08
CAGE:65678
============= Composition/Information on Ingredients =============
Ingred Name:COLUMBIA CARBON, CARBON BLACK, LAMPBLACK, BLACK PEARLS
(IARC CARC GROUP 3) - *96-2*
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 5-10%
Other REC Limits:3.5 MG/CUM (NIOSH)
OSHA PEL:3.5 MG/CUM
ACGIH TLV:3.5 MG/CUM
Ingred Name:STYRENE, METHACRYLIC ACID, BUTYL METHACRYLATE, BUTYL
ACRYLATE POLYMER
CAS:58048-89-8
Fraction by Wt: 80-90%
Ingred Name:PROPENE POLYMERS, POLYPROPYLENE, POLYOLEFINE (SUSP CARC IA
RC GRP 3) *96-2*
CAS:9003-07-4
RTECS #:UD1842000
Fraction by Wt: 1-5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MINIMAL RESPIRATORY TRACT
IRRITATION MAY OCCUR AS W/EXPOSURE TO LARGE AMOUNTS OF ANY
NON-TOXIC DUST.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & WATER. EYES: FLUSH THOROUGHLY W/WATER.
INGESTION: DILUTE STOMACH CONTENTS W/SEVERAL GLASSES OF WATER.
INHALATION: PROMPTLY REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION
IN ALL CASE S.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, FOAM/DRY CHEMICAL, CO2
Fire Fighting Procedures:IF PRODUCT BECOMES INVOLVED IN A FIRE, USE
CO2.
Unusual Fire/Explosion Hazard:NONE UNDER NORMAL STORAGE & USE
CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP W/A VACUUM CLEANER.
======================Handling and Storage ======================
Handling and Storage Precautions:CLOSE CAP TIGHTLY & STORE IN A COOL,
DRY & DARK PLACE.
Other Precautions:AVOID COMBUSTION. AVOID INHALATION, INGESTION,
SKIN/EYE CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DUST FILTER RESPIRATOR RECOMMENDED WHEN HANDLING
BULK AMOUNTS.
Ventilation:NONE REQUIRED UNDER NORMAL USE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:>250.4F
Spec Gravity:1.1
Solubility in Water:INSOLUBLE
Appearance and Odor:FINE BLACK POWDER, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE IN NORMAL HANDLING & USE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:208, FULLER-O'BRIEN AND CROWN SOLVENT- (SUPP DATA)
CAGE:FO983
CAGE:72556
CAGE:FO983
============= Composition/Information on Ingredients =============
Ingred Name:ZINC OXIDE
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: < 5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10MG/M3 TDUST
Ingred Name:VOLATILE ORGANIC COMPOUND: 250-440 G/L
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPP DATA:MONOGRAPHS, SUPPLEMENT. VOL 7, PG 341, 1987:GRP2.
NTP 6TH ANNUAL REPORT ON CARCIN, 1991:ANTIC TO BE CARCIN.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVERXP:CAUSE DMG TO KID/LIV/LUNGS/BLOOD CELLS,
BLOOD PRODUCING ORG (MARROW), BLOOD STORING ORG (SPLEEN) & PNS.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: WITH A RAG AND WASH THOROUGHLY WITH SOAP
AND WATER.
RTECS #:9999999ZZ
Ingred Name:VENT: LIMIT. FOR BAKING FINISHES, VENT VAPORS EMITTED ON
HEATING.
RTECS #:9999999ZZ
Ingred Name:XYLENE (SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: < 5%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM;150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ALUMINUM (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 5%
OSHA PEL:15MG/M3 DUST;5 FUME
ACGIH TLV:10MG/M3 DUST
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (AROMATIC
SOLVENT (B))
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: < 5%
OSHA PEL:N/K
ACGIH TLV:100 PPM
Ingred Name:BARIUM SULFATE (DUST)
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: <0.1%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:BENZENE (SARA III)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: <0.1%
OSHA PEL:N/K
ACGIH TLV:10 PPM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 5%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:CHROMIUM (SARA III)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: < 5%
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: < 5%
OSHA PEL:10 MG/M3 RDUST
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE
CAS:14464-46-1
RTECS #:VV7325000
Fraction by Wt: < 5%
OSHA PEL:SEE TABLE
ACGIH TLV:0.05 MG/M3 RDUST
Ingred Name:SILICIC ACID, TETRAETHYL ESTER; (ETHYL SILICATE)
CAS:78-10-4
RTECS #:VV9450000
Fraction by Wt: < 5%
OSHA PEL:100 PPM
ACGIH TLV:10 PPM
Ingred Name:SILICATE, MICA; (MICA (MINERAL))
CAS:12001-26-2
RTECS #:VV8760000
Fraction by Wt: < 5%
OSHA PEL:20 MPPCF; Z-3
ACGIH TLV:3 MG/M3 RDUST
Ingred Name:MINERAL SPIRITS (F)
CAS:64742-88-7
Fraction by Wt: 40%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:MINERAL SPIRITS (G)
CAS:64742-88-7
Fraction by Wt: 5%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:MINERAL SPIRITS; (ODORLESS MINERAL SPIRITS)
CAS:64742-88-7
Fraction by Wt: 10%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:MINERAL SPIRITS; (PETROLEUM NAPHTHA (H))
CAS:64742-88-7
Fraction by Wt: 5%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:SILICON DIOXIDE, AMORPHOUS
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: < 5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (TALC)
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 5%
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M2 RDUST
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 15%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INGEST:CAUSES IRRIT TO MOUTH,
THROAT & GI TRACT W/ACUTE CNS DEPRESS. SYMPS MAY INCL HDCH, DIZZ,
CONFUSION, NAUS, VOMIT, ABDOM PAIN, DIARR,
UNCON/COMA.INHAL:ANESTHETIC. IRRIT OF RESP TRACT & ACUT E NERV SYS
DEPRESS CHARAC BY THE FOLLOWING PROGRESSIVE STEPS:HDCH, DIZZ, STAG
GAIT, CONFUSION, UNCON OR(EFTS OF OVEREXP)
Explanation of Carcinogenicity:CHROMIUM: IARC MONOGRAPHS, VOL 49,PG 49,
1990: GRP 1. NTP: ANNUAL REPORT ON CARCIN, 1991: KNOWN TO BE
CARCIN.(SUPP DATA)
Effects of Overexposure:HLTH HAZ:COMA. EYE:CAN CAUSE SEV IRRIT &
BLURRED VISION. SKIN:CAUSES IRRIT. PRLNG/RPTD CNTCT MAY RSLT IN
DERM. CHRONIC:REPORTS HAVE ASSOC PRLNGD & RPTD OCCUP OVEREXP TO
SOLVS W/PERM BRAIN & CNS DMG. I NTENTIONAL MISUSE BY DELIB CONC &
INHALCONTENTS MAY BE HARMFUL/FATAL. CHRONIC EXPOS TO SOLVS HAS BEEN
SHOWN TO (ING 23)
Medical Cond Aggravated by Exposure:ING 4:BIO EXPOS INDICES INCL PHENOL
IN URINE & BENZENE IN EXHALER AIR. ING 8:EXISTING LUNG DISEASES; A
LUNG TOXIN. ING 19: BIO EXPOS INDICES INCL METHYLHIPPURIC ACIDS IN
URINE.
======================= First Aid Measures =======================
First Aid:INGEST:DRINK 1-2 GLASSES OF H*2O TO DILUTE. KEEP PERSON WARM,
QUIET & GET MED ATTN IMMED. DECISION TO INDUCE VOMIT MUST BE BASED
ON ADVICE OF A MD/POIS CTL CTR. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCO N PERSON. INHAL:REMOVE TO FRESH AIR. RESTORE BRTHG. CONSULT
MD. EYE:IMMED FLUSH W/COOL H*2O FOR @ LST 15 MIN, OCCSNLY LIFTING
LIDS TO ENSURE THORO RINSING. SEND FOR ASSISTANCE. SKIN: WIPE
OFF(ING 24)
===================== Fire Fighting Measures =====================
Flash Point:105F,41C
Lower Limits:1.0%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROT EQUIP
. WATER MAY BE USED TO COOL CLSD CNTNRS TO PVNT PRESS BUILD-UP &
POSS AUTOIGNIT/EXPLO WHEN (SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT/SPARKS/FLAME/ELEC EQUIP. CLSD CNTNRS MAY EXPLODE WHEN EXPOSED
TO EXTREME HEAT. APPLIC TO HOT SUFS (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION. SOAK UP AND REMOVE
WITH INERT ABSORBENT MATERIAL WITH NON-SPARKING TOOLS. PROVIDE
ADEQUATE VENTILATION. USE APPROVED VAPOR RESPIRATOR.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE UPRIGHT IN SEALED CONTAINERS AND
USE AWAY FROM HIGH TEMPS, SPARKS AND FLAME. AVOID PROLONGED CONTACT
WITH SKIN.
Other Precautions:DO NOT INGEST. KEEP CONTAINER TIGHTLY SEALED WHEN NOT
IN USE. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD PROPERLY FITTED MECH RESP OR
MASK TO AVOID BRTHG VAP/SPRAY MIST DURING MIXING, SPRAYING,
APPLICATION OR CURING. NIOSH/MSHA APPRVD PROPERLY FITTED POSITIVE
AIR SUPPLIED RESP IN CONFIN ED AREAS OR WHEN OVERSPRAY IS PRESENT.
Ventilation:SUFFICIENT VENT IN VOL & PATTERN TO KEEP AIR CONTAM CONC
BELOW APPLIC OSHA PERMISSIBLE EXPOS LEVEL/ACGIH'S TLV (ING 25)
Other Protective Equipment:PROTECTIVE OVERALLS RECOMMENDED. REMOVE AND
WASH CONTAM CLTHG. DISCARD CONTAM SHOES.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR TRADE NAME/PART NO: BASED ARCHITECTURAL COATING. FIRE FIGHT
PROC:EXPSD TO EXTREME HEAT. EXPLO HAZ:REQUIRES SPECIAL PRECS.
DURING EMER CNDTNS, OVEREXP TO DECOMP PRODS MAY CAUSE HLTH HAZ.
OBTAIN MEDATTN. EXPLAN OF CARCIN: HUMAN/ANIMAL: LUNG CANCER,
SKIN. SILICA, CRYSTALLINE-(QUARTZ,CRISTOBALITE): IARC (ING 22)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>241F,>116C
Vapor Density:HVR/AIR
Spec Gravity:1.3
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:60
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS, BASES
Stability Condition to Avoid:HIGH TEMPERATURE.
Hazardous Decomposition Products:MAY PRODUCE FUMES WHEN HEATED TO
DECOMPOSITION. FUMES MAY CONTAIN CO, CO*2, AND NO*2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN SEALED METAL CONTAINER AWAY FROM HEAT
AND FLAME IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
DO NOT INCINERATE CLOSED CONTAINERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:057 MOORLASTIC LIGHTWEIGHT SPACKLING COMPOUND
CAGE:91950
CAGE:91950
============= Composition/Information on Ingredients =============
Ingred Name:GLASS, OXIDE, CHEMICALS
CAS:65997-17-3
= Wt:17.5
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INHALATION: CAUSES NOSE & THROAT
IRRITATION; LUNG IRRITATION. SKIN/EYES: PRIMARY IRRITANT.
INGESTION: LARGE AMOUNTS COULD CAUSE SERIOUS INJURY.
Explanation of Carcinogenicity:THIS PRODUCT CONTAINS ONE/MORE REPORTED
CARCINOGENS/SUSPECTED CARCINOGENS WHICH ARE NOTED.
Effects of Overexposure:IRRITATION
Medical Cond Aggravated by Exposure:NONE EXPECTED WHEN USED IAW/SAFE
HANDLING & USE INFORMATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH THOROUGHLY
W/WATER. SKIN: WASH W/SOAP & WATER. INGESTION: DRINK 1-2 GLASSES OF
WATER TO DILUTE. DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN
ALL CASE S.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>121.1C, 250.F
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:COOL EXPOSED CONTAINERS W/WATER. USE SELF
CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:TOXIC GASES MAY FORM WHEN PRODUCT BURNS.
CLOSED CONTAINERS MAY BURST IF EXPOSED TO EXTREME HEAT/FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH W/WATER. ABSORB W/SAWDUST/RAGS.
======================Handling and Storage ======================
Handling and Storage Precautions:CLOSE CONTAINER AFTER EACH USE. KEEP
OUT OF REACH OF CHILDREN. DON'T THROW/DROP CONTAINERS.
Other Precautions:AVOID CONTACT W/EYES & PROLONGED CONTACT
W/SKIN/BREATHING OF SPRAY MIST/SANDING DUST. DON'T TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR SPECIFIED FOR
PROTECTION AGAINST PAINT SPRAY MIST & SANDING DUST IN
RESTRICTED/CONFINED AREAS.
Ventilation:ADEQUATE TO MAINTAIN WORKING ATMOSPHERE BELOW TLV & LEL.
MECHANICAL EXHAUST IN CONFINED AREAS.
Other Protective Equipment:CLOTHING ADEQUATE TO PROTECT SKIN.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE. WASH HANDS BEFORE EATING, SMOKING/USING THE WASHROOM.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:31.1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:ELEVATED TEMPERATURES, EXTREME HEAT/FIRE.
Hazardous Decomposition Products:BURNING MAY PRODUCE CO2, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T INCINERATE SEALED CONTAINERS. DISPOSE OF
IN ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
===================== Regulatory Information =====================
State Regulatory Information:THIS PRODUCT MAY CONTAIN SMALL AMOUNTS OF
MATERIALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER &
REPRODUCTIVE HARM.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:RUBBER PROTECTANT,ZR-2550
CAGE:62692
CAGE:62692
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM HYDROCARBONS (TRADE SECRET)
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS UNKNOWN.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY &
GI TRACTS. ACUTE- EYES:CAN CAUSE SEVERE IRRITATION, BLURRED VISION.
SKIN:PROLONGED/REPEATED CONTACT CAUSES MODERATE IRRITATION,
DERMATITIS. INHALE:RESPIRATORY IR RITATION, HEADACHE, DIZZINESS,
FATIGUE.ORAL:NAUSEA, VOMITING, DIARRHEA, GASTROINTESTINAL
IRRITATION.CHRONIC-DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:HEADACHE, DIZZINESS, NAUSEA, IRRITATION OF
EYES, SKIN, RESPIRATORY AND GASTROINTESTINAL TRACTS; VOMITING,
DIARRHEA, DIFFICULTY IN BREATHING, FATIGUE, NOSE AND THROAT
IRRITATION
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. INHALED: REMOVE TO
FRESH AIR. PROVIDE OXYGEN/CPR IF NEEDED. EYES: FLUSH WITH WATER FOR
15 MINUTES. KEEP EYELIDS OPEN. SKIN: REMOVE PRODUCT FROM SKIN WITH
WAT ERLESS SOAP, WIPE OFF CLEAN, THEN WASH WITH SOAP & WARM WATER.
INGESTION: DO NOT INDUCE VOMITING. IF VOMITING OCCURS, KEEP HEAD
BELOW HIPS. CALL PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:106F,41C
Extinguishing Media:USE CARBON DIOXIDE, FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH-APPROVED SELF CONTAINED BREATHING
APPARATUS. COOL FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:VAPOR IS HEAVIER THAN AIR AND CAN TRAVEL
CONSIDERABLE DISTANCE OR BE MOVED BY VENTILATION TO A SOURCE OF
IGNITION AND FLASH BACK. CONTAINER MAY EXPLODE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR APPROPRIATE RESPIRATORY PROTECTION AND
PROTECTIVE CLOTHING. CONTAIN SPILLED MATERIAL. TRANSFER TO SECURE
CONTAINERS. WHERE NECESSARY, COLLECT USING ABSORBENT MEDIA SUCH AS
SAND/VERMICULITE. ELIMI NATE ANY SOURCE OF IGNITION. VENTILATE
AREA.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, VENTILATED AREA, AWAY
FROM HEAT, FLAMES, SPARKS & INCOMPATIBLE MATERIALS. USE APPROVED
BONDING AND GROUNDING PROCEDURES.
Other Precautions:USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER
HANDLING AND BEFORE EATING OR DRINKING. DO NOT GET IN EYES, ON SKIN
OR ON CLOTHING. DO NOT BREATHE VAPOR AND SPRAY MIST. KEEP OUT OF
REACH OF CHILD REN. DO NOT USE NEAR WELDING EQUIPMENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL(TLV), USE NIOSH APPROVED RESPIRATORS.
RESPIRATORS SHOULD BE SELECTED BASED ON THE FORM AND CONCENTRATION
OF CONTAMINANT IN AIR & IN ACCO RDANCE WITH OSHA (29 CFR 1910.134).
Ventilation:MECHANICAL (GENERAL AND/OR LOCAL EXHAUST, EXPLOSION-PROOF)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER,
INDUSTRIAL-TYPE WORK CLOTHING, APRON AND BARRIER CREAM FOR EXPOSED
SKIN
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:318F - 386F
Vapor Pres:2.6 @ 68F
Vapor Density:5.4
Spec Gravity:0.8236
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:INSOLUBLE/NIL
Appearance and Odor:DARK REDISH-BROWN LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, SPARKS, OPEN FLAMES, HOT
SURFACES AND OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN, VARIOUS HYDROCARBONS
==================== Disposal Considerations ====================
Waste Disposal Methods:ALL RECOVERED MATERIAL SHOULD BE PACKAGED,
LABELED, TRANSPORTED, AND DISPOSED OR RECLAIMED IN ACCORDANCE WITH
ALL APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS.
INCINERATE IN APPROVED FACIL ITY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CONTACT CLEANER (BULK) 3072, 3073
Preparer's Name:A. B. REED
CAGE:10136
CAGE:10136
============= Composition/Information on Ingredients =============
Ingred Name:1,1,2-TRICHLORO-1,2,2-TRIFLUOROETHANE (FREON 113) (SARA
III)
CAS:76-13-1
RTECS #:KJ4000000
Fraction by Wt: 100%
Other REC Limits:1000 PPM
OSHA PEL:1000PPM/1250STEL
ACGIH TLV:1000PPM/1250STEL9192
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CHLOROFLUOROCARBON MATERIALS HAVE
PRODUCED SENSITIZATION OF THE MYOCARDIUM TO EPINEPHRINE IN
LABORATORY ANIMALS (DOGS), AND COULD HAVE A SIMILAR EFFECT IN
HUMANS, RESULTING IN A FATAL CARDIAC ARRHYTHM IA. DO NOT USE
EPINEPHRINE OR ITS CONGENERS IN PERSONS EXPOSED TO THESE COMPOUNDS
.
Explanation of Carcinogenicity:N/K
Effects of Overexposure:INHAL: DROWSINESS, LIGHTHEADEDNESS POSSIBLE
CARDIAC ARRHYTHMIAS AT HIGH CONCENTRATION. SKIN: DEFATTING ACTION,
MAY CAUSE DERMATITIS. EYES: MAY IRRITATE EYES. CHRONIC
OVEREXPOSURE-MAY CAUSE SKIN IRRITA TION WITH REPEATED SKIN CONTACT.
Medical Cond Aggravated by Exposure:IMPAIRED CARDIOVASCULAR FUNCTION
SUCH AS CARDIAC ARRHYTHMIAS MIGHT BE SENSITIZED BY INHALATION.
======================= First Aid Measures =======================
First Aid:IF SYMPTOMS PERSIST CALL A PHYS. REMOVE TO FRESH AIR. APPLY
ARTIFICIAL RESP IF NECESSARY (MFR). REMOVE TO FRESH AIR. SUPPORT
BREATHING (GIVE O*2/ ARTIFICIAL RESPIRATION) . EYES: FLUSH WITH
LARGE AMOUNTS OF WATER (MFR). FLUSH WITH PLENTY OF POTABLE WATER
FOR AT LEAST 15 MINUTES, THEN OBTAIN PROMPT MEDICAL ATTENTION .
SKIN: WASH WITH WATER. INGEST: INDUCE VOMITING, CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:NOT NEEDED (MFR). USE APPROPRIATE MEDIA FOR
SURROUNDING FIRE .
Fire Fighting Procedures:NONE (MFR) WEAR PRESSURE DEMAND SELF-CONTAINED
BREATHING APPARATUS AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MATERIAL VAPORIZES QUICKLY (MFR) THERMAL
DECOMPOSITION PRODUCTS MAY INCLUDE FLUORIDES, CHLORIDES AND
PHOSGENE .
================== Accidental Release Measures ==================
Spill Release Procedures:DUE TO HIGH VOLATILITY, MATERIAL QUICKLY
EVAPORATES. VENTILATE AREA, EVACUATE PERSONNEL UNTIL CONCENTRATION
IS BELOW TLV OR USE SELF-CONTAINED BREATHING APPARATUS.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL DRY AREA.
Other Precautions:VAPORS ARE VERY HEAVY AND WILL COLLECT IN LOW AREAS.
O*2 WOULD BE DISPLACED + ASPHYXIATION COULD RESULT. GOOD VENT IS A
MUST FOR LOW AREAS + CONFINED SPACES (MFR). NO SMOKING IN AREA OF
USE. DO NOT US E IN THE GEN VICINITY OF ARC, (SUP DATA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELF CONTAINED BREATHING APPARATUS ABOVE TLV
(MFR). NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF
CONCERN .
Ventilation:MAINTAIN CONCENTRATION BELOW TLV
Other Protective Equipment:PROTECTIVE CLOTHING ONLY IF THERE IS
REPEATED CONTACT WITH LIQUID
Work Hygienic Practices:OBSERVE GOOD WORK HYGIENIC PRACTICES
Supplemental Safety and Health
SOLUBILITY: SLIGHT IN WATER, SOLUBLE IN MANY ORGANIC LIQUIDS. FREEZING
POINT -35.7 F; -37.2 C. OTHER PREC: WELDING, OPEN FLAMES OR HOT
SURFACES. HEAT AND/OR UV RADIATION MAY CAUSE THE FORMATION OF CHL
ORIDES, FLUORIDES OR PHOSGENE .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:117 F;47 C
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:5.5 PSIA
Vapor Density:6.5(AIR=1)
Spec Gravity:1.57
Evaporation Rate & Reference:0.3 (CARBON TET = 1)
Solubility in Water:SEE SUP DATA
Appearance and Odor:COLORLESS LIQUID
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
POWDERED METALS SUCH AS ALUMINUM, MAGNESIUM, CALCIUM, ZINC
Stability Condition to Avoid:N/K
Hazardous Decomposition Products:HALOGENS, HALOGEN ACIDS, POSSIBILITY
OF PHOSGENE (THERMAL) (MFR). CHLORIDES, FLUORIDES AND PHOSGENE .
==================== Disposal Considerations ====================
Waste Disposal Methods:IF POSSIBLE PUMP INTO DRUMS FOR RECLAMATION
(MFR). DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL, STATE, AND
LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TELLUS(R) OIL 68, SHELL CODE:65211
Preparer's Name:J.C. WILLETT
CAGE:54527
CAGE:54527
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENT REFINED, HYDROTREATED HEAVY PARAFFINIC DISTILLATE
CAS:64742-54-7
RTECS #:PY8035500
Fraction by Wt: 98-99%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:MINOR ADDITIVES
Fraction by Wt: 1-2%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYE:BASED ON COMPONENT INFO PROD
PRESUMED TO BE PRACTICALLY NON-IRRIT.PROLONG/REPEAT SKIN CONTACT
MAY RESULT IN SKIN DISORDERS(DERM,OIL ACNE,FOLLICULITIS).ACCIDENTAL
RELEASE UNDER HI PRESSURE APP LICATIONS MAY RESULT IN INJECTION OF
OIL INTO SKIN CAUSING LOCAL NECROSIS.INHAL:VAP(FRM HI TEMP)/OIL
MIST MAY CAUSE(SUP)
Explanation of Carcinogenicity:PER MSDS:PROD & COMPONENTS NOT
CLASSIFIED AS CARCINOGENS BY IARC/NTP/OSHA.
Effects of Overexposure:IRRITATION OF MUC MEMBRANE OF UPPER RESP TRACT.
NECROSIS MY BE EVIDENCED BY DELAYED ONSET OF PAIN & TISSUE DAMAGE A
FEW HOURS FOLLOWING HIGH PRESSURE INJECTION.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN & RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYE:SLUFH W/WATER.IRRIT OCCURS GET MED ATTN. SKIN:REMOVE
CONTAMIN CLOTH/SHOES.WIPE EXCESS OFF.FLUSH W/WATER.FOLLOW BY
WASHING W/SOAP/WATER.IRRIT OCCURS GET MED ATTN.IF MATL INJECTED
UNDER SKIN GET MEDATTN PROMPTLY TO PREVENT SERIOUS DAMAGE.DON'T
WAIT FOR SYMPTOMS TO DEVELOP.INHAL:REMOVE TO FRESH AIR.IN GENERAL
NO TREATMENT NECESSARY UNLESS LG AMTS INGEST.GET MED ADVICE.DR:IN
GENERAL EMESIS(SUPPL)
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:400F,204C
Extinguishing Media:USE WATERFOG,FOAM,DRY CHEMICAL,CO2.DO NOT USE
DIRECT STREAM OF WTER.PROD WILL FLOAT & CAN REIGN ON SURFACE OF
WATER.
Fire Fighting Procedures:MATL WILL NOT BURN UNLESS PREHEATED.DO NOT
ENTER CONFINED FIRE SPACE W/O FULL BUNKER
SCBA.
Unusual Fire/Explosion Hazard:COOL FIRE EXPOSED CNTNRS W/WATER.
================== Accidental Release Measures ==================
Spill Release Procedures:MAY BURN ALTHOUGH NOT READILY IGN.USE CAUTIOUS
JUDGMENT WHEN CLEANING LG SPILLS.WEAR RESP/PROT CLOTH AS
APPROPRIATE.STOP LEAK W/O RISK.DIKE/CONTAIN.REMOVE W/VACUUM
TRUCKS/PUMP TO VESSELS.SOAK RESIDUE
W/ABSORBENT(CLAY,SAND,ETC)FLUSH AREA W/WATER(SUPP)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:MIN SKIN CONTACT.SOTRE IN COOL, DRY PALCE W/ADEQUATE
VENTILATION.KEEP AWAY FROM OPEN FLAMES & HIGH TEMPERATURES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPO MAY OR DOES EXCEED OCCUPATINAL EXPO
LIMITS USE NIOSH APPROVED RESP TO PREVENT OVEREXPO. IN ACCORDA
W/29CFR1910.134 USE EITHER AN ATM-SUPPLYING RESP OR AIR-PURIFYING
RESP FOR ORG VAP & PARTICUL ATES.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:CHEMICAL RESISTANT PROT CLOTHING AS REQUIRED
TO MIN SKIN CONTACT.
Work Hygienic Practices:WASH W/SOAP/WATER BEF EAT/DRINK/SMOKE/TOILET
USE.WASH CONTAMIN CLOTH BEF REUES.PROPERLY DISPOSE CONTAMIN LEATHER
ARTICLE
Supplemental Safety and Health
HAZ DECOMP PROD:C0 & OTHER UNIDENTIFIED ORG CMPDS MAY BE FORMED. HEALTH
HAZ:CAUSE MILD MUC MEMB OF UPPER RESP TRACT IRRIT.INGEST:BASED ON
COMPONENT INFO PROD IS NO MORE THAN SLIGHTLY TOXIC. 1STAID:IND
UCTIN UNNECESSARY IN HI VISCOSITY LOW VOLATILITY PROD(MOST OILS &
GREASES). SPILL:TO REMOVE TRACE RESIDE.SM SPILL ABSORB
================== Physical/Chemical Properties ==================
HCC:V6
Melt/Freeze Pt:M.P/F.P Text:-5F POUR PT
Vapor Pres:<0.1
Spec Gravity:0.8789
Viscosity:61-75CS @104F
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CRAM WHITE LIQUID, SLIGHT HYDROCARBON ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS.
Stability Condition to Avoid:AVOID HEAT, OPDN FLAMES.
Hazardous Decomposition Products:PROD HIGHLY DEPENDENT ON COMBUSTION
CONDITIONS.COMPLEX MIX OF AIRBORNE SOLID/LIQ/PART/GAS WILL EVOLVE
IN PYRO/COMB (SUP)
==================== Disposal Considerations ====================
Waste Disposal Methods:PROD DOESN'T CONTAIN/WAS NOT DRECTLY MFG W/ANY
CLASS I/II OZONE DEPLETING SUBSTANCES.BASED ON DATA AVAILABLE TO
SHELL PROD CONTAINS NO SUBSTANCES SUB TO REPORTING/PLANNING REQMTS
UNDER SARA TITLE III. MATL IS OIL & SPILLS ENTERING WATER MUST BE
REPORT
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:CALCO DIESEL FUEL NO. 1
CAGE:0AHD1
CAGE:0AHD1
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM MID-DISTILLATE
CAS:8008-20-6
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Effects of Overexposure:MAY CAUSE SKIN IRRITATION. PROLONGED BREATHING
OF THE VAPOR CAN CAUSE NERVOUS SYSTEM EFFECTS.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH QUICKLY WITH FRESH WATER FOR 15 MIN.WHILE HOLDING
EYELIDS OPEN.SKIN:WASH WELL WITH SOAP AND WATER.SEE A DOCTOR IF
IRRITATION OCCURS.LAUNDER CONTAMINATED CLOTHING.INHALATION:MOVE
PERSON TO F RESH AIR.IF SWALLOWED,GIVE WATER OR MILK TO DRINK AND
PRODUCT CONTAINER TO THE NEAREST EMERGENCY TREATMENT CENTER.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:100 DEG F
Extinguishing Media:CO2,DRY CHEMICAL,FOAM,WATER FOG
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED FIRE SPACE WITHOUT
PROPER PROTECTIVE EQUIPMENT.USE SELF-CONTAINED BREATHING APPARATUS
TO PROTECT AGAINST OXYGEN DEFICIENCY.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ANY FLAME SOURCE AT AREA OF
SPILL.STOP THE LEAK SOURCE AND PREVENT ANY LEAKAGE FROM
CONTAMINATING SOIL OR SURFACE WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE NEAR FLAME,SPARKS OR HOT
SURFACES. USE ONLY IN WELL VENTILATED AREA. KEEP CONTAINER CLOSED.
Other Precautions:READ AND OBSERVE ALL PRECAUTIONS ON LABEL.DO NOT
WELD,HEAT OR DRILL CONTAINERS.REPLACE CAP OR BUNG.EMPTIED
CONTAINERS STILL CONTAIN HAZARDOUS OR EXPLOSIVE VAPOR OR LIQUID.DO
NOT USE PRESSURE TO EMPTY DRUM OR EXPLOSION MAY RESULT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:THIS MATERIAL MAY BE AN INHALATION HAZARD AND
UNLESS VENTILATION IS ADEQUATE,THE USE OF AN APPROVED RESPIRATOR IS
RECOMMENDED.
Ventilation:USE THIS MATERIAL ONLY IN WELL VENTILATED AREAS.
Supplemental Safety and Health
NOT FOR USE AS A PORTABLE HEATER OR APPLIANCE FUEL.TOXIC FUMES MAY
ACCUMULATE AND CAUSE DEATH.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:215-288C
Spec Gravity:0.85-0.811
Solubility in Water:INSOLUBLE
Appearance and Odor:PALE YELLOW LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY REACT WITH STRONG OXIDIZING MATERIALS.
Hazardous Decomposition Products:NORMAL COMBUSTION FORMS CARBON DIOXIDE
AND WATER VAPOR; INCOMPLETE COMBUSTION CAN PRODUCE CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE CONTAMINATED MATERIALS IN DISPOSABLE
CONTAINERS AND DISPOSE OF IN A MANNER CONSISTENT WITH APPLICABLE
REGULATIONS.CONTACT LOCAL ENVIRONMENTAL OR HEALTH AUTHORITIES FOR
APPROVED DISPOSAL OF THIS MATERIAL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS & NICKEL ALLOY COMPOSITION
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:JET FUEL JP-4
Preparer's Name:STEPHEN A. ELBERT
CAGE:15958
CAGE:15958
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM NAPHTHA
Other REC Limits:NONE RECOMMENDED
Ingred Name:PETROLEUM DISTILLATE
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 OIL MIST
ACGIH TLV:5 MG/M3 OIL MIST
Ingred Name:BENZENE (SARA III)
CAS:71-43-2
RTECS #:CY1400000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1PPM/5STEL;1910.1028
ACGIH TLV:10 PPM; A2; 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:EYES: MILDLY IRRITATING. SKIN:
PROLONGED AND REPEATED LIQUID CONTACT CAN CAUSE DEFATTING AND
DRYING RESULTING IN SKIN IRRITATION AND DERMATITIS.INHALATION: MAY
CAUSE IRRITATION OF NOSE, THROAT, RESPIR ATORY TRACT AND CNS
DEPRESSION. MAY PRODUCE LIVER AND KIDNEY DAMAGE. INGESTION: MAY BE
HARMFUL OR FATAL IF SWALLOWED.
Explanation of Carcinogenicity:CONTAINS B[71-43-2] WHICH IS
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:EYES: IRRITATION. SKIN: IRRITATION, DERMATITIS.
INHALATION: RESPIRATORY TRACT IRRITATION, HEADACHE, DIZZINESS,
GIDDINESS, AND NAUSEA. KIDNEY DAMAGE NOTED BY CHANGES IN URINE
OUTPUT, EDEMA. LIVER DAMA GE NOTED BY LOSS OF APPETITE,JAUNDICE AND
PAIN IN LIVER AREA.
Medical Cond Aggravated by Exposure:PREEXISTING EYE, SKIN, AND
RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE. ALSO IMPAIRED
LIVER AND KIDNEY FUNCTIONS FROM PREEXISTING DISORDERS MAY BE
AGGRAVATED BY EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. GET MEDICAL
ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. WASH AREA WITH SOAP
AND WATER. IF IRRITATION PERSISTS GET MEDICAL ATTENTION.
INHALATION: MOVE TO FRE SH AIR. IF NOT BREATHING GIVE CPR. IF
BREATHING DIFFICULT GIVE OXYGEN. GET MEDICAL ATTENTION. INGESTION:
DO NOT INDUCE VOMITING. GET MEDICAL ATENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:-10F TO 30F
Lower Limits:1.3
Upper Limits:8.0
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEMICAL OR CARBON
DIOXIDE. DO NOT USE DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND
REIGNITE.
Fire Fighting Procedures:EXTREMELY FLAMMABLE. WEAR FIRE FIGHTING
PROTECTIVE EQUIPMENT AND A FULL FACED SELF CONTAINED BREATHING
APPARATUS. COOL FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR, ACCUMULATE
IN LOW AREAS AND TRAVEL ALONG GROUND TO DISTANT SOURCES OF IGNITION
AND FLASHBACK.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. GROUND HANDLING
EQUIPMENT TO PREVENT SPARKING. DIKE TO CONTAIN SPILL. PUMP TO
SALVAGE CONTAINER. SOAK UP RESIDUE WITH AN ABSORBENT. PLACE IN
CONTAINER FOR DISPOSAL. FLUSH A REA WITH WATER. CONTAIN FLUSH WATER
FORDISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED. PROTECT
CONTAINERS FROM PHYSICAL DAMAGE.
Other Precautions:ALL HANDLING EQUIPMENT MUST BE GROUNDED TO PREVENT
SPARKING.DO NOT SIPHON GASOLINE BY MOUTH. FOR USE AS FUEL ONLY. DO
NOT USE AS A CLEANING SOLVENT OR OTHER NON-MOTOR FUEL USES.
REMEMBER EXPLOSION AND FIRE IS THE MOST IMMEDIATE DANGER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMALLY NOT NEEDED AT AMBIENT TEMPERATURE. IF
EXPOSURE EXCEEDS PEL USE A NIOSH-APPROVED RESPIRATOR TO PREVENT
OVEREXPOSURE. USE A FULL-FACE SUPPLIED-AIR RESPIRATOR FOR ORGANIC
VAPORS IN ENCLOSED SPAC ES.
Ventilation:USE EXPLOSION-PROOF VENTILATION AS REQUIRED TO CONTROL
VAPOR CONCENTRATIONS.
Other Protective Equipment:IMPERVIOUS CLOTHING TO PREVENT SKIN CONTACT.
EYE WASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
EXPLOSION AND FIRE IS THE MOST IMMEDIATE DANGER. KEEP ALL CONTAINERS
CLOSED WHEN NOT IN USE. DO NOT HANDLE OR STORE NEAR HEAT, SPARKS,
FLAME OR STRONG OXIDANTS. VENTILATION MUST BE SUFFICIENT TO PREVE
NT EXCEEDING EXPOSURE LIMITS OR BUILDUPOF EXPLOSIVE CONCENTRATIONS
OF VAPOR.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:250F,121C
Vapor Pres:2-3 PSI
Spec Gravity:0.75
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS LIQUID, FUEL OIL ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, FLAMES, AND
STATIC CHARGES. PREVENT VAPOR ACCUMULATION.
Hazardous Decomposition Products:FUMES, SMOKE, CARBON MONOXIDE AND
OTHER UNIDENTIFIED ORGANIC COMPOUNDS CAN BE FORMED UPON COMBUSTION.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS. KEEP PRODUCT OUT OF SURFACE WATERS AND ANY
WATER COURSES OR SEWERS ENTERING OR LEADING TO SURFACE WATERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FA17034
CAGE:JO774
CAGE:81831
CAGE:JO774
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMED.SKIN:WASH W/SOAP IMMED.INHAL:REMOVE
TO FRESH AIR.GIVE ART.RESPIR. AS NEEDED.INGEST:GET MEDICAL
ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE VOMITING,BUT DO NOT MAKE
UNCONSCIOUS PE RSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS.CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE,THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW COLORED LIQUID,AROMATIC ODOR.
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CARBON DIOXIDE,GAS
CAGE:5H199
CAGE:62882
CAGE:5H199
============= Composition/Information on Ingredients =============
Ingred Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: 99.5%MIN
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM/30000STEL;95
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV IS 5000 PPM.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:LUNGS, HEART, CNS, EYES,
SKIN. ACUTE- CONTACT WITH LIQUID CAN CAUSE SKIN FROSTBITE. GAS MAY
CAUSE EYE IRRITATION. ASPHYXIANT. INHALATION MAY CAUSE RESPIRATORY
ACIDOSIS. HIGH CONCENTRATIO NS MAY CAUSE RAPID CIRCULATORY
INSUFFICIENCY LEADING TO DEATH. INGESTION UNLIKELY. CHRONIC-
UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, FROSTBITE, HEADACHE, DROWSINESS,
DIZZINESS, STINGING OF THE EYES, NOSE AND THROAT, EXCITATION, RAPID
BREATHING AND HEART RATE, EXCESS SALIVATION, SHORTNESS OF BREATH,
MUSCULAR WEAKNESS, RI NGING IN THE EAR, UNCONSCIOUSNESS, COMA,
NAUSEA, VOMITING, WATERY EYES (FORMATION OF WEAK CABONIC ACID)
Medical Cond Aggravated by Exposure:PERSONNEL WITH PRE-EXISTING CHRONIC
RESPIRATORY DISEASES OR HEART DISORDERS SHOULD REFRAIN FROM
BREATHING EXCESSIVE CARBON DIOXIDE.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. PROVIDE CPR/OXYGEN IF NEEDED.
EYES:IMMEDIATELY FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SEE AN
OPHTHALMOLOGIST, URGENTLY. SKIN:FLUSH WITH WARM WATER (NOT TO
EXCEED 107 F). PROMPT MEDICAL ATTENTION IS MANDATORY IN ALL CASES
OF OVEREXPOSURE TO CO2. RESCUE PERSONNEL SHOULD BE EQUIPPED WITH
SELF CONTAINED BREATHING APPARATUS. ORAL:TREAT SYMPTOMATICALLY.
CALL PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:CARBON DIOXIDE CANNOT CATCH FIRE. USE WATER FOG,
CARBON DIOXIDE, FOAM, OR DRY CHEMICAL FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
NIOSH-APPROVED SELF CONTAINED BREATHING APPARATUS. COOL FIRE
EXPOSED CONTAINERS WITH WATER SPRAY. EVACUATE AREA.
Unusual Fire/Explosion Hazard:CYLINDERS MAY EXPLODE DUE TO HEAT OF
FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:LIQUID CARBON DIOXIDE WILL FORM SOLID CO2 (DRY
ICE) WHEN RELEASED TO ATMOSPHERIC PRESSURE. THE AREA SHOULD BE
VENTILATED. CLEAN UP PERSONNEL SHOULD WEAR SELF-CONTAINED BREATHING
APPARATUS WITH FULL FA CE MASK AND HEAVY PROTECTIVE CLOTHING.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, WELL-VENTILATED DARK
PLACE. NEVER WORK ON A PRESSURIZED SYSTEM. IF THERE IS A LEAK,
CLOSE THE CYLINDER VALVE AND BLOW DOWN THE SYSTEM
Other Precautions:KEEP AWAY FROM SOURCES OF HEAT. CAUTION! CAN CAUSE
RAPID SUFFOCATION DUE TO OXYGEN DEFICIENCY. USE WITH ADEQUATE
VENTILATION. CO2 IS HEAVIER THAN AIR AND TENDS TO ACCUMULATE NEAR
THE FLOOR IN CLOSED S PACES. READ ALL LABELS AND INSTRUCTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL USE. HOWEVER,
AIR-SUPPLIED RESPIRATORS ARE REQUIRED WHILE WORKING IN CONFINED
SPACES WITH THIS PRODUCT. THE RESPIRATORY PROTECTION USE MUST
CONFORM WITH OSHA RULES AS SPECIF IED IN 29 CFR 1910.134.
Ventilation:SUFFICIENT TO PREVENT ACCUMULATION ABOVE TLV. LOCAL EXHAUST
LOCATED NEAR THE FLOOR.
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER,
INDUSTRIAL-TYPE WORK CLOTHING, SAFETY SHOES AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:G3
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:-109F SUBLI
Melt/Freeze Pt:M.P/F.P Text:-70F@3929MM
Vapor Pres:42963 @68F
Vapor Density:1.53
Spec Gravity:1.10 @ -35F
pH:ACIDIC
Viscosity:NOT RELEVANT
Evaporation Rate & Reference:NOT RELEVANT
Solubility in Water:SOLUBLE
Appearance and Odor:COLORLESS, ODORLESS GAS
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MATERIALS THAT REACT WITH CABONIC ACID SUCH AS ALKALIES
Stability Condition to Avoid:OVERHEATING CYLINDERS
Hazardous Decomposition Products:CAN DECOMPOSE TO CARBON MONOXIDE AND
OXYGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:SLOWLY RELEASE INTO ATMOSPHERE OUTDOORS.
DISPOSAL SHOULD BE IN COMPLIANCE WITH ALL LOCAL, STATE AND FEDERAL
REGULATIONS. DEFECTIVE CYLINDERS SHOULD BE TAGGED TO INDICATE A
DEFECT.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:186 5310 EKTAPRINT 2 DEVELOPER REPLENISHER, PART D
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 55-60%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM CARBONATE
CAS:584-08-7
RTECS #:TS7750000
Fraction by Wt: 30-35%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM SULFITE
CAS:10117-38-1
RTECS #:WT3530000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SUBSTITUTED PHOSPHONATE
CAS:2809-21-4
RTECS #:SZ8562100
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: EXPECTED TO BE A LOW
HAZARD FOR RECOMMENDED HANDLING. EYE: CAUSES BURNS. SKIN:CAUSES
BURNS. INGESTION: HARMFUL IF SWALLOWED. MAY CAUSE BURNS OF
GASTROINTESTINAL TRACT IF SWALLOWED.
Explanation of Carcinogenicity:PER MSDS:NONE.
Effects of Overexposure:EYE & SKIN BURNS. BURNS OF GASTROINTESTINAL
TRACT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:IF SYMTOMATIC MOVE TO FRESH AIR. GET MED ATTN IF
SYMPTOMS PERISIST. EYE:IMMED FLUSH W/PLENTY OF WATER FOR @LEAST
15MINS. GET MED ATTN IMMED. SKIN:IMMED FLUSH/PLENTY OF WATER FOR
@LEAST 15MINS WH ILE REMOVING CONTAMIN CLOTH/SHOES. GET MED ATTN.
INGEST:DO NOT INDUCE VOMITING. GIVE VICTIM A GLASS OF WATER. NEVER
GIVE ANYTHING BY MOUTH IF UNCONSC. CALL PHYCISIAN OR POISON CONTROL
CENTER IMMED.
===================== Fire Fighting Measures =====================
Flash Point:NONCOMBUSTIBLE
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER W/LG AMTS OF WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT GET IN EYES/SKIN/CLOTHING.USE
W/ADEQU VENTILATION. KEEP CNTNR CLOSED.KEEP AWAY FROM INCOMPATIBLE
SUBSTANCES.
Other Precautions:STRONGLY ALKALINE AQU SOLN.NO BIOCHEM OXYG DEMAN & NO
POT TO CUASE OXY DEPLETION IN AQU SYS,LOW POT TO AFFECTS AQU
ORGANISMS & 2ND WASTE TREAT MICROBIAL METABOLISM &
GERMINATION/EARLY GROWTH OF PLANTS& BIOCONC.DILUTED W/LG AMTS OF
(SUPPLE)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD VENTILATION (TYPICALLY 4-6 RM VOL/HR) SHOULD BE USED.
VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS.
Other Protective Equipment:DECONTAMINATION FACILITIES:WASHING
FACILITIES.PROT CLOTHING APPROPRIATE FOR EXPO RISK.WASH CONTAMIN
CLOTH BEF REUSE.
Work Hygienic Practices:WASH THOROUGHLY AFT HANLDING.FOLLOW GOOD
INDUSTRIAL HYGIENE PRAC TO PREVENT EYE CONTACT/MIN SKIN
CONTACT/INHAL.
Supplemental Safety and Health
OTHER PRECAUT:WATER MATL RELEASED DIRE/INDIR INTO ENVIRO IS NOT
EXPECTED TO HAVE SIGNIFICANT IMPACT. TO MAKE 5 GALLONS. PER
TIR:ITEM CANCELLED ON 95060 W/O REPLACEMENT.
================== Physical/Chemical Properties ==================
HCC:B1
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:18MM @20C
Vapor Density:0.6
Spec Gravity:1.42
pH:>13
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID, COLORLESS, ODORLESS.
Percent Volatiles by Volume:55-60
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:HAZ COMBUST PROD:NONE
(NON-COMBUSTIBLE).
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE/TREATMENT/DISPOSAL MAY BE SUBJECT TO
NATIONAL/STATE/LOCAL LAWS. FLUSH TO SEWER W/LG AMTS OF WATER. NO
CHEM SUBJECT TO REPORTING REQMTS OF SEC 313, TIT III OF
SARA/40CFR372.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:7270P WESTO-FLOC
Preparer's Name:FRED HOPKINS
CAGE:FO909
CAGE:FO909
CAGE:08824
============= Composition/Information on Ingredients =============
Ingred Name:HYDROCHLORIC ACID, HYDROGEN CHLORIDE, MURIATIC ACID
HYDROCHLORIDE
CAS:7647-01-0
RTECS #:MW4025000
Fraction by Wt: <10%
Other REC Limits:7 PPM
OSHA PEL:5 PPM
ACGIH TLV:C 11 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES, SKIN, INHALATION, & INGESTION:
IRRITATION. PERMANENT DAMAGE MAY OCCUR IF OVEREXPOSED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES & SKIN: BURNING. INHALATION: BURNING OF
UPPERRESPIRATORY TRACT. INGESTION: BURNING OF MOUTH, THROAT, &
GASTROINTESTINAL TRACT.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: FLUSH W/WATER FOR 15
MINS. INHALATION: REMOVE TO FRESH AIR. IF BREATHING DIFFICULT OR
STOPPED, GIVE OXYGEN OR CPR. INGESTION: HAVE PATIENT RINSE MOUTH &
GARGLE W /WATER, & SPIT OUT RINSATE. THEN DRINK LARGE GLASS OF
WATER. DON'T INDUCE VOMITING. REMOVE CONTAMINATED CLOTHING &
FOOTWEAR. DON'T FORCE FLUIDS IF UNCONSCIOUS. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:>250F
Extinguishing Media:WATER, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING & POSITIVE PRESSURE
SCBA.
Unusual Fire/Explosion Hazard:NOT NORMALLY COMBUSTIBLE; HOWEVER, IF
WATER CONTENT IS LOST (AS IN FIRE), FLAMMABLE RESIDUES OR VAPORS
MAY BE PRESENT.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR ADEQUATE PERSONAL PROTECTIVE EQUIPMENT &
CLOTHING. CONTAIN & CLEAN UP W/INERT ABSORBENT MATERIAL & PLACE IN
APPROVED CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:CORROSIVE - HANDLE W/CARE. STORE IN
COOL WELL VENTILATED AREA AWAY FROM INCOMPATIBLE MATERIALS. KEEP
TIGHTLY CLOSED. DON'T MIX WITH OTHER CHEMICALS.
Other Precautions:DON'T ADD WATER TO CONCENTRATE, ALWAYS ADD PRODUCT TO
WATER USING CAUTION & AGITATION. CHANGES IN TEMPERATURE CREATE AIR
PRESSURE IN DRUMS. USE CAUTION IN UNSCREWING PLUG & INSERTING
FAUCET. PROTECT C ONTAINERS FROM DAMAGE. DON'T BREATH MIST
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF MIST IS GENERATED, WEAR ACID PARTICULATE
RESPIRATOR.
Ventilation:MECHANICAL (GENERAL): ADEQUATE.
Other Protective Equipment:LONG SLEEVEED SHIRT & LONG PANTS. WATER
SOURCE, SAFETY SHOWER, EMERGENCY EYE WASH STATION.
Work Hygienic Practices:WASH AFTER HANDLING.
Supplemental Safety and Health
PRECAUTION: DON'T GET IN EYES OR ON SKIN OR CLOTHING. DON'T WEAR
CONTACT LENSES. THIS MATERIAL IS AN AMINOMETHYLATED FLAVANOID
POLYMER. IT COULD ALSO BE DESCRIBED AS BEING A CONDENSED TANNIN.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>300F
Vapor Density:0.99-1.00
Spec Gravity:1.09-1.10
pH: 2.0
Solubility in Water:COMPLETE
Appearance and Odor:TAN LIQUID, SLIGHT SWEET ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALUMINUM, COPPER, MILD STEEL CONTAINERS, BRASS, ZINC, GALVANIZED
MATERIAL, BASES, OXIDIZERS.
Stability Condition to Avoid:TEMPERATURES >100F MAY CAUSE GELLING.
Hazardous Decomposition Products:CO, CO2, FORMALDEHYDE, AMMONIA,
HYDROGEN CHLORIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:SPILLED & UNUSED MATERIAL WHICH CAN'T BE
RECYCLED OR RE-USED, MAY BE CORROSIVE HAZARDOUS WASTE. DISPOSE
I/A/W LOCAL, STATE & FEDERAL REGULATIONS. REPORTABLE QUANITY: 100
LBS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HEXGARD 540 TYPE 1&2; BLUE SEAL; HEXPRESS
Preparer's Name:D. CROSS
CAGE:EO076
CAGE:04621
CAGE:EO076
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
OSHA PEL:15MG/M3 DUST/5 FUME
ACGIH TLV:10MG/M3 DUST; 9192
Ingred Name:ASBESTOS (FRIABLE)(SARA III)
CAS:1332-21-4
RTECS #:CI6425000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE 1910.1001
ACGIH TLV:0.2 - 2 FIBER/CC; 94
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ALUMINUM (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15MG/M3 DUST/5 FUME
ACGIH TLV:10MG/M3 DUST; 9394
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: INHALATION OF DUST MAY CAUSE
MILD RESPIRATORY IRRITATION. CONTACT WITH DUST MAY CAUSE EYE
IRRITATION. NO HEALTH EFFECTS NOTED FOR INGESTION. CHRONIC:
PROLONGED OR REPEATED EXPOSURE MAY CAUSE SK IN IRRITATION OR LUNG
CANCER.
Explanation of Carcinogenicity:CONTAINS A [1332-21-4] WHICH IS
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:INHALED: COUGHING, SHORTNESS OF BREATH,
SNEEZING, WHEEZING. EYES: REDNESS, DISCOMFORT. SKIN: REDNESS,
DISCOMFORT. INGESTED: NONE NOTED.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALED: REMOVE TO FRESH AIR. EYES: FLUSH WITH LOTS OF WATER
FOR 15 MINUTES, HOLD LIDS OPEN. SEE DOCTOR IF SYMPTOMS PERSIST.
SKIN: WASH WITH SOAP AND WATER. INGESTED: NONE NOTED.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:CARBON DIOXIDE, WATER, DRY CHEMICAL, FOAM
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE CLOTHING SHOULD BE WORN IN ALL FIRES INVOLVING
CHEMICALS.
Unusual Fire/Explosion Hazard:DUST GENERATED FROM MACHINING OPERATIONS
SHOULD NOT BE EXPOSED TO MOISTURE; IT MAY LIBERATE FLAMMABLE
HYDROGEN GAS AND FORM EXPLOSIVE MIXTURES.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:PRACTICES SHOULD BE IN ACCORDANCE WITH NFPA 65
STANDARD FOR THE PROCESSING AND FINISHING OF ALUMINUM.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. IF ENGINEERING CONTROLS
FAIL; USE NIOSH/MSHA APPROVED RESPIRATOR WITH DUST CARTRIDGE. USE
IN ACCORDANCE WITH 29 CFR 1910.134.
Ventilation:USE LOCAL EXHAUST TO MAINTAIN EXPOSURE BELOW TLV/PEL.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
CERTAIN ADHESIVES USED IN THE MANUFACTURE OF METALLIC HONEYCOMB PANELS
CONTAIN A SMALL PERCENTAGE OF ASBESTOS. UNDER NORMAL CONDITIONS,
THE ASBESTOS IS BOUND INTO THE ADHESIVE AND DOES NOT CREATE AN E
XPOSURE TO THE USER. MACHINING OF THIS PRODUCT, MAY HOWEVER,
LIBERATE FIBERS OF ASBESTOS, AN OSHA REGULATED CARCINOGEN.
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:METALLIC HONETCOMB PANEL MATERIAL WITH NO
DISTINCTIVE ODOR.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE ANTICIPATED
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NO APPRECIABLE DECOMPOSITION BELOW
550F.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT WITH CERTIFIED WASTE DISPOSAL
CONTRACTOR. DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:OMC HI-VIS GEAR LUBE 31-250, 173244
CAGE:7X110
CAGE:7X110
============= Composition/Information on Ingredients =============
Ingred Name:REFINED HEAVY PARAFFINIC DISTILLATES
CAS:64741-88-4
Fraction by Wt: 97-99%
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:REFINED PETROLEUM OIL(S)
CAS:64742-01-4
Fraction by Wt: 97-99%
Ingred Name:EXTREME PRESSURE, OXIDATION AND RUST INHIBITOR
Fraction by Wt: 1-4%
Ingred Name:VI IMPROVER
Fraction by Wt: <0.1%
Ingred Name:SUPP DATA: ADVICE. SUS VISCOSITY AT 100 F=740.
RTECS #:9999999ZZ
Ingred Name:VENT: MANDATED STANDARDS AS EVALUATED BY DESIGNATED
PERSONNEL.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL,RAT) >15 G/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: LOW RISK OF INHAL. IN
ENCLOSED SPACES/WHEN HOT, VAPS MAY REACH CONC SUFFICIENT TO CAUSE
DROW, DIZZ, HDCH, NAUS/LUNG IRRIT. MISTS ABOVE TLV MAY CAUSE CHEM
PNEUM. SKIN: LOW IRRIT. SKIN ABS ORP: NO PROBABLE ACUTE HAZ. EYE:
MAY BEMILDLY IRRIT. INGEST: GENERALLY LOW TOXICITY. VERY LRG (SEE
EFTS OF OVEREXP)
Explanation of Carcinogenicity:REFINED HEAVY PARAFFINIC
DISTILLATES:LISTED IN IARC AS A GROUP 1 CARCINOGEN.
Effects of Overexposure:HLTH HAZ: AMTS MAY CAUSE GENERALIZED
DEPRESSION, HDCH, DROW, NAUS, VOMIT/DIARRHEA. SMALL DOSES MAY
PRODUCE IRRITATION & DIARRHEA. INJECTION: ERYTHEMA, EDEMA, IRRIT.
CHRONIC: PROLONGED AND/OR FREQUENTCONTACT MAY CAUSE DRYING,
CRACKING (DERMATITIS) OR FOLLICULITIS.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. RESP SUPPORT IF NEC. SEEK MED
AID. SKIN: WASH W/SOAP & H2O. DO NOT WEAR HEAVILY CONTAM CLTHG
BEFORE LAUNDERING. EYES: FLUSH W/LRG VOL OF H2O. SEE PHYS IF ANY
COMPLICATIONS ARISE. INGEST: DO NOT INDUCE VOMIT. SEEK MED AID.
INJECTION: SUBCUTANEOUS INJECTION IS MED EMER. SEEK MED AID IMMED.
NOTES TO PHYS: IF VISCOSITY IS < 100 SUS @ 100 F, CAREFUL GASTRIC
LAVAGE(SUP DAT)
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:460F,238C
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:WATER MAY CAUSE FROTHING.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF HEAT/IGNIT, PROVIDE ADEQUATE
VENTILATION, CONTAIN LEAK. SMALL SPILLS: ABSORB W/SUITABLE MATERIAL
SUCH AS RAGS, STRAW/SAND. LRG SPILLS: CONTAIN SPILL IN EARTHEN
DIKES FOR LATER RECOVE RY. REPORT SPILLS AS REQD TO APPROP
AUTHORITIES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 150 F. DO NOT APPLY HIGH
HEAT OR FLAME TO CONTAINER. KEEP SEPARATE FROM STRONG OXIDIZING
AGENTS.
Other Precautions:EMPTY CONTAINERS MAY CONTAIN PRODUCT RESIDUE WHICH
COULD INCLUDE FLAM/EXPLO VAPORS. CONSULT APPROP FED, STATE & LOCAL
AUTHORITIES BEFORE REUSING, RECONDITIONING, RECLAIMING,
RECYCLING/DISP OF EMPTY CN TNRS &/OR WASTE RESIDUES OF PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMALLY NONE REQUIRED. IF HIGH VAPOR OR MIST
CONCENTRATIONS EXPECTED-USE NIOSH/MSHA APPROVED RESPIRATOR FOR
ORGANIC VAPORS AND MISTS.
Ventilation:USE IN WELL VENT AREA. IN CONFINED SPACED, MECH VENT MAY BE
REQD TO KEEP LEVS OF CERTAIN COMPONENTS BELOW (INGRED 6)
Other Protective Equipment:WEAR BODY-COVERING WORK CLOTHES TO AVOID
PROLONGED OR REPEATED EXPOSURE. LAUNDER SOILED WORK CLOTHES BEFORE
REUSE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
% VOLAT: NEGLIGIBLE. FIRST AID PROC: W/TIGHT FITTING/CUFFED TUBE IS TO
BE PREFERRED OVER EMESIS. IF VISCOSITY IS >100 SUS AT 100 F, EMESIS
MAY BE INDUCED FOR LRG QTYS. ASPIR MAY CAUSE CHEM PNEUM/LIPOI D
PNEUM. SUBCUTANEOUS INJECTION REQS PROMPT SURGICAL DEBRIDEMENT. IF
NOT FAMILIAR W/TECHNIQUE, SEEK SKILLED (ING 5)
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:750F,399C
Vapor Pres:<3 X 10-4
Vapor Density:>1
Spec Gravity:0.89
Evaporation Rate & Reference:<1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER LIQUID, SLIGHT SULFURIZED ODOR.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:CO2 (CO UNDER INCOMPLETE COMBUSTION)
==================== Disposal Considerations ====================
Waste Disposal Methods:IT IS RESPONSIBILITY OF USER TO DETERMINE IF
MATL IS HAZ WASTE AT TIME OF DISP. CHECK BEFORE DISPOSING TO BE
SURE YOU ARE IN COMPLIANCE WITH ALL FEDERAL, STATE, AND LOCAL
REGULATIONS. CHEMTREC/RCRA EM ERGENCY NUMBER: 800-424-9346.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:#5356, WELDING WIRE
Preparer's Name:STEPHEN ANDERSON
CAGE:7Z608
CAGE:7Z608
============= Composition/Information on Ingredients =============
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: 0.25%
Other REC Limits:NONE SPECIFI
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: 0.40%
Other REC Limits:NONE SPECIFI
OSHA PEL:10 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:COPPER (SARA III)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 0.10%
Other REC Limits:NONE SPECIFI
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2MG/M3 FUME; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: .05-0.2%
Other REC Limits:NONE SPECIFI
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:ZINC OXIDE
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: 0.1%
Other REC Limits:NONE SPECIFI
OSHA PEL:15MG/M3 TDUST/5 FUME
ACGIH TLV:10MG/M3 TDUST; 9293
Ingred Name:MAGNESIUM
CAS:7439-95-4
RTECS #:OM2100000
Fraction by Wt: 4.5-5.5%
Other REC Limits:NONE SPECIFI
Ingred Name:CHROMIUM (SARA III)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: .05-0.2%
Other REC Limits:NONE SPECIFI
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TITANIUM, METAL
CAS:7440-32-6
RTECS #:XR1700000
Fraction by Wt: .06-0.2%
Other REC Limits:NONE SPECIFI
OSHA PEL:10 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:ALUMINUM (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: REMNDR
Other REC Limits:NONE SPECIFI
OSHA PEL:15MG/M3 DUST/5 FUME
ACGIH TLV:10MG/M3 DUST; 9192
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SHORT TERM EXPOSURE TO WELDING FUMES,
GASES OR DUST MAY RESULT IN DISCOMFORT SUCH AS DIZZINESS, NAUSEA,
FEVER, DRYNESS AND/OR IRRITATION OF NOSE, THROAT AND EYES. SKIN
SENSITIVITY MAY ALSO BE NOTED. A CUTE EXPOSURE FROM SOME TOXIC
GASES MAYCAUSE PULMONARY EDEMA, ASPHYXIATION AND EXCESSIVE EXPOSURE
CAN BE FATAL.
Explanation of Carcinogenicity:CONTAINS CHROMIUM, WHICH IS LISTED BY
NTP AND IARC AS A CARCINOGEN.
Effects of Overexposure:FUMES CAN CAUSE IRRITATION, DIZZINESS, WATERY
EYES, HEADACHE, NAUSEA, BREATHING DIFFICULTY, COUGHING, CHEST
PAINS. COPPER FUMES MAY CAUSE METAL FUME FEVER WHICH MAY INCLUDE
FEVER, BODY ACHE, CHILLS. A RC RAYS CAN INJURE EYES & BURN SKIN.
ELECTRIC SHOCK CAN KILL. IR RADIATION CAN INJURE EYES.
Medical Cond Aggravated by Exposure:PERSONS WITH IMPAIRED PULMONARY
FUNCTION, AND CONDITIONS SUCH AS ASTHMA, EMPHYSEMA, CHRONIC
BRONCHITIS, ETC... CAN BE AGGRAVATED BY THE EXPOSURE.
======================= First Aid Measures =======================
First Aid:IN CASE OF ELECTRICAL SHOCK, TURN OFF POWER PRIOR TO REMOVAL
FROM EXPOSURE AREA AND ADMINISTRATION OF FIRST AID. REMOVE FROM
EXPOSURE AREA AND CALL FOR MEDICAL AID. ADMINISTER OXYGEN IF
BREATHING IS D IFFICULT. IF NOT BREATHING, BEGIN ARTIFICIAL
RESPIRATION. IF NO DETECTABLE PULSE, BEGIN EXTERNAL HEART MASSAGE.
EMPLOY FIRST AID TECHNIQUES RECOMMENDED BY THE AMERICAN RED CROSS.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:CLASS "D" DRY CHEMICAL. DO NOT USE WATER. WATER MAY
REACT WITH BURNING ALUMINUM VIOLENTLY.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND NIOSH-
APPROVED SELF-CONTAINED BREATHING APPARATUS WITH FULL FACEPIECE
OPERATED IN THE POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:MOLTEN METAL ALLOYS MAY EXPLODE ON
CONTACT WITH WATER. RUST AND CERTAIN METAL OXIDES (OXIDES OF
COPPER,IRON) MAY ALSO REACT VIOLENTLY WITH WATER.
================== Accidental Release Measures ==================
Spill Release Procedures:IN SOLID FORM THIS MATERIAL POSES NO SPECIAL
CLEAN-UP PROBLEMS. JUST PICK UP AND SAVE.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE-STORE IN A COOL,DRY,WELL
VENTILATED AREA AWAY FROM MOISTURE, ACIDS.
Other Precautions:AVOID BREATHING OF FUMES. USE WITH ADEQUATE
VENTILATION. WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING AND
DRINKING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED SUPPLIED AIR RESPIRATORY
PROTECTION OR RESPIRABLE FUME RESPIRATOR WHEN WELDING, BRAZING OR
SOLDERING IN CONFINED SPACE OR WHERE LOCAL EXHAUST OR VENTILATION
DOES NOT KEEP EXPOS URE BELOW TLV.
Ventilation:LOCAL EXHAUST VENTILATION SHOULD BE USED TO CONTROL
EXPOSURE TO AIRBORNE FUMES WHENEVER POSSIBLE.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER, WORK
CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING.
Supplemental Safety and Health
FORMULA CHANGED. FOR PREVIOUS FORMULATION, SEE P/N A UNDER THE SAME
NSN.
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:INSOLUBLE
Appearance and Odor:SOLID SILVERY WIRE, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:METAL OXIDES, FUMES, FLUORIDES, OZONE
AND NITROGEN OXIDES MAY BE FORMED DURING WELDING.
==================== Disposal Considerations ====================
Waste Disposal Methods:PRIOR TO DISPOSAL, CONSIDER IF MATERIAL HAS
RECOVERY VALUE. DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE AND
FEDERAL REGULATIONS. PREVENT WASTE FROM CONTAMINATING ENVIRONMENT.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:252S SYNTHETIC ENAMEL, TRACTOR & IMPLEMENT ENAMELS
Preparer's Name:T R LOUER
CAGE:23027
CAGE:90227
CAGE:23027
============= Composition/Information on Ingredients =============
Ingred Name:SOYBEAN OIL, POLYMER W/GLYCEROL & PHTHALIC ANHYDRIDE
*96-4*
CAS:66070-61-9
Ingred Name:SOYBEAN OIL, POLYMER WITH BENZOIC ACID, PENTAERYTHRITOL AND
PHTHALIC ANHYDRIDE
CAS:67922-66-1
Ingred Name:PHTHALIC ANHYDRIDE, GLYCERIN, LINSEED OIL RESIN
CAS:66070-59-5
Ingred Name:SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC, HIGH FLASH
AROMATIC NAPHTHA, C8&10 AROMATIC HYDROCARBON *96-4*
CAS:64742-95-6
RTECS #:WF3400000
Ingred Name:LEAD NAPHTHENATE
CAS:61790-14-5
RTECS #:QK9150000
Fraction by Wt: 0.4%
Other REC Limits:0.10 MG/CUM
ACGIH TLV:0.15 MG/CUM INORG PB
Ingred Name:MEDIUM ALIPHATIC NAPHTHA (AROMATIC 100), PARAFFIN-NAPTHANES
MINERAL SPIRITS *96-4*
CAS:64742-88-7
Other REC Limits:100 PPM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
CARCINOGEN, IARC GROUP 3)*96-4*
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA, LACOLENE *96-4*
CAS:64742-89-8
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *96-4*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 38%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOLATILE ORGANIC CONTENT: 4.6 LBS/GAL
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: GASTROINTESTINAL DISTRESS.
INHALATION: NOSE & THROAT IRRITANT. REPEATED/PROLONGED OVEREXPOSURE
TO SOLVENTS MAY LEAD TO PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
EYES: IRRITATION/BURNING. SKI N: REPEATED/PROLONGED CONTACT MAY
CAUSEIRRITATION, DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:GI DISTRESS, IRRITATION, EYE WATERING,
HEADACHES, NAUSEA, DIZZIESS, LOSS OF COORDINATION, BURNING,
DISCOMFORT
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: IMMEDIATELY FLUSH
W/PLENTY OF WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:<73F
Lower Limits:0.8
Upper Limits:23
Extinguishing Media:WATER SPRAY, FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT W/SCBA. WATER
FROM FOG NOZZLES MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT
PRESSURE BUILDUP.
Unusual Fire/Explosion Hazard:WHEN HEATED >FLASHPOINT, EMITS FLAMMABLE
VAPORS WHICH, WHEN MIXED W/AIR, CAN BURN/BE EXPLOSIVE. FINE
MISTS/SPRAYS MAY BE FLAMMABLE AT TEMPS 120F. KEEP AWAY FROM
HEAT, SPARKS & FLAME. CLOSE CONTAINER AFTER EACH USE. GROUND
CONTAINERS WHEN POURING.
Other Precautions:DON'T SAND, FLAME CUT, BRAZE/WELD DRY COATING W/O A
NIOSH/MSHA APPROVED RESPIRATOR/APPROPRIATE VENTILATION. OBSERVE
LABEL PRECAUTIONS. DON'T BREATHE VAPORS/MISTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR PROPERLY FITTED VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA (TC-23C) FOR USE W/PAINTS DURING
APPLICATION/UNTIL ALL VAPORS & SPRAY MISTS ARE EXHAUSTED. CONFINED
SPACES: WEAR A POSITIVE-PRE SSURE, SUPPLIED-AIR RESPIRATOR
(TC-19C).
Ventilation:SUFFICIENT IN VOLUME & PATTERN TO KEEP CONTAMINANTS BELOW
APPLICABLE OSHA REQUIREMENTS.
Other Protective Equipment:COVERALLS
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE
EATING/SMOKING.
Supplemental Safety and Health
% VOLATILE BY VOLUME: 59.7-69.5%.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:129-734F
Vapor Density:>1
Evaporation Rate & Reference:LESS THAN ETHER
Solubility in Water:MISCIBLE
Percent Volatiles by Volume:(SUPP)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS, FLAME & OTHER IGNITION
SOURCES
Hazardous Decomposition Products:CO, CO2, SMOKE
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T ALLOW MATERIAL TO CONTAMINATE GROUND WATER
SYSTEMS. INCINERATE ABSORBED MATERIAL IAW/LOCAL, STATE & FEDERAL
REGULATIONS. DON'T INCINERATE IN CLOSED CONTAINERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TYPE L GREASE 49-08-4170
CAGE:40817
CAGE:40817
============= Composition/Information on Ingredients =============
Ingred Name:MIXTURE OF SEVERELY HYDROTREATED PETROLEUM HYDROCARBON BASE
STOCK CONTAINING ING 2-4
RTECS #:9999999ZZ
Ingred Name:SOLVENT REFINED HYDROTREATED RESIDUAL OIL
CAS:64742-57-0
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SOLVENT, DEWAXED RESIDUAL OIL (PETROLEUM)
CAS:64742-62-7
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SEVEVERLY HYDROTREATED PETROLEUM BASE STOCK
CAS:64742-58-1
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC: PROLONGED OR REPEATED
SKIN CONTACT TENDS TO REMOVE SKIN OILS AND MAY CAUSE SKIN
IRRITATION. EXPOSURE TO FUMES/MISTS MAY CAUSE MUCOUS MEMBRANE
IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:MILD IRRITATION OF SKIN AND MUCOUS MEMBRANE.
======================= First Aid Measures =======================
First Aid:SKIN: WIPE OFF AND WASH WITH SOAP AND WATER. EYE: FLUSH WITH
COPIOUS AMOUNTS OF WATER FOR AT LEAST 15 MINUTES AND SEE A MD.
INHAL: REMOVE FROM EXPOSURE TO FRESH AIR. INGEST: ADMINISTER WATER.
DO NOT I NDUCE VOMITING. SEEK MEDICAL AID.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:356F,180C
Extinguishing Media:CO2, DRY CHEMICAL, FOAM AND WATER FOG. (CAREFUL TO
PREVENT FROTHING).
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP FLOW. ELIMINATE IGNITION SOURCE. RECOVER
FREE PRODUCT. ADD ABSORBENT MATERIAL SUCH AS CLAY TO SPILL AREA.
SWEEP/SCRAP UP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED. HANDLE AND
STORE USING METHODS GENERALLY ADVOCATED FOR PETROLEUM PRODUCTS. DO
NOT STORE/MIX W/OXIDIZING MATERIALS.
Other Precautions:AVOID EXCESSIVE HEAT/FLAMES. AVOID REPEATED CONTACT
W/ SKIN. AVOID CONTACT WITH EYES AND INHALATION OF FUMES,
VAPORS/MISTS. DON'T INGEST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMALLY NOT REQUIRED. NIOSH/MSHA APPROVED
RESPIRATOR RECOMMENDED IF FUMING OR MISTING.
Ventilation:LOC EXHST: RECOMMENDED TO CAPTURE HOT FUMES. MECH:
RECOMMENDED IF FUMING OR MISTING.
Other Protective Equipment:NORMALLY NOT REQUIRED.
Work Hygienic Practices:WASH HANDS BEFORE EAT/DRINK. DO NOT WEAR
CONTAMD CLTHG. REMOVE & LAUNDER BEFORE RE-USE. WASH THOROUGHLY
AFTER HNDLG.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:V6
Melt/Freeze Pt:M.P/F.P Text:>480F,>249C
Spec Gravity:0.9(H2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GREENISH-GRAY GREASE, CHARACTERISTIC ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT AND OPEN FLAMES.
Hazardous Decomposition Products:OXIDES OF CARBON MAY FORM ON
INCOMPLETE COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AS LOCAL LAWS PERMIT FOR PETROLEUM
HYDROCARBONS. DISPOSE OF I/A/W FEDERAL, STATE AND LOCAL REGULATIONS
.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ZYTEL, 42HSX NC010
Kit Part:Y
Preparer's Name:D.L. LICZWEK
CAGE:B0589
CAGE:82348
CAGE:B0589
============= Composition/Information on Ingredients =============
Ingred Name:NYLON (NYLON 66)
CAS:32131-17-2
Fraction by Wt: >98%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:LUBRICANT
Fraction by Wt: <2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:STABILIZER
Fraction by Wt: <2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:MAY NOT PROVIDE ADEQ PROTECTION.
RTECS #:9999999ZZ
Ingred Name:EYE PROT:SHIELD WHEN POSSIBILITY EXISTS FOR EYE & FACE CONT
DUE TO SPLASHING/SPRAYING OF MOLTEN MATL. NIOSH/MSHA (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:FULL FACE MASK RESP PROVIDES PROTECTION FROM EYE
IRRITATION.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT)>10,000 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:SINGLE LG ORAL EXPOS (10,000
MG/KG) PRODUCED ONLY SLIGHT INITIAL WEIGHT LOSS. TWO-YEAR TESTS IN
RATS & ONE YEAR TESTS IN DOGS @ LEV OF 10% IN DIET PRODUCED NO
ADVERSE EFTS. RPTD INHAL EXPOS PROD UCED NO GROSS CHANGES & ONLY
MICROSCOPIC LUNG & KIDNEY CHANGES. THE CMPD IS NOT SKIN IRRITANT.
TESTS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:IN ANIMALS DEMONSTRATE NO CARCIN
ACITIVITY. NO ADVERSE HLTH EFTS ARE EXPECTED FROM HUMAN EXPOS TO
POLYHEXAMETHYLENE ADIPAMIDE, EXCEPT FOR MECH IRRIT OF SKIN & EYES
CAUSE BY PARTICLES. SIGNIFI CANT SKIN PERMEATION, AND SYSTEMIC
TOX,AFTER CONTACT APPEARS UNLIKELY.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:CONSULT PHYS IF NEC. IF EXPOS TO FUMES FROM
OVERHEATING/COMBUST, MOVE TO FRESH AIR. CONSULT PHYS IF SYMP
PERSIST. SKIN:CLEANSING SKIN AFTER USE IS ADVISABLE. IF MOLTEN
POLYMER GETS ON SKIN, COOLRAPIDLY W/COLD WATER. DO NOT ATTEMTP TO
PEEL POLYMER FROM SKIN. OBTAIN MED TREATMENT FOR THERMAL BURN.
EYE:IMMED FLUSH W/PLENTY OF WATER FOR @ LEAST 15 MINS. CALL PHYS.
INGEST:CONSULT PHYS IF NEC.
===================== Fire Fighting Measures =====================
Flash Point:752F,400C
Extinguishing Media:WATER, FOAM, DRY CHEMICAL, CO*2.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . KEEP PERSONNEL REMOVED AND UPWIND OF FIRE.
Unusual Fire/Explosion Hazard:LG MOLTEN MASSES MAY IGNITE SPONT IN AIR.
WATER QUENCHING OF SUCH MASSES IS GOOD PRACTICE. HAZ GASES/VAP
PRODUCED IN FIRE ARE:AMMONIA, CO; SM AMTS OF (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:NOTE:REVIEW FIRE FIGHT MEASURES & HNDLG (PERS)
SECTIONS BEFORE PROCEEDING W/CLEAN-UP. USE APPROP PERSONAL PROT
EQUIP DURING CLEAN-UP. SWEEP UP TO PVNT A SLIPPING HAZARD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:COOL, DRY PLACE. KEEP CNTNRS TIGHTLY
CLSD TO PVNT MOISTURE ABSORPTION & CONTAMINATION.
Other Precautions:MEDICAL USE: CAUTION:DO NOT USE IN MED APPLIC
INVOLVING PERM IMPLANTATION IN HUMAN BODY. FOR OTHER MED APPLIC SEE
DU PONT CAUTION BULLETIN NO. H-50102.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD AIR PURIFYING RESP W/ORG VAP
CARTRIDGE & NIOSH/MSHA DUST/MIST FILTER MAY BE PERMISSIBLE UNDER
CERTAIN CIRCUMSTANCES WHERE AIRBORNE CONC ARE EXPECTED TO EXCEED
EXPOS LIM. PROT PROVIDE D BY NIOSH/MSHA AIR PURIFYING (SUPDAT)
Ventilation:LOCAL VENTL TO CONTROL FUMES FROM HOT PROCESSING.
Other Protective Equipment:IF THERE IS POTENTIAL CONT W/HOT MOLTEN
MATL, WEAR HEAT RESIST CLOTHING AND FOOTWEAR.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
% VOLAT:1% (WATER). EXPLO HAZ:HYDROGEN CYANIDE & ALDEHYDES. WASTE DISP
METH:PROVINCIAL, & LOCAL REGS. RESP PROT:RESP IS LIM. USE
NIOSH/MSHA POSITIVE PRESS AIR SUPPLIED RESP IF THERE IS ANY POTNTL
FOR UNCONTROLLED RELEASE, EXPOS LEV ARE NOTKNOWN, OR ANY OTHER
CIRCUMSTANCE WHERE NIOSH/MSHA AIR PURIFYING RESP (ING 4)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>482F,>250C
Spec Gravity:1.22-1.38
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:INSOLUBLE
Appearance and Odor:GRANULES, NO ODOR
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND OXIDIZING AGENTS.
Stability Condition to Avoid:HEATING ABOVE 340 DEGREES C.
Hazardous Decomposition Products:CYCLOPENTANONE, CARBON MONOXIDE,
ALDEHYDES, AND AMMONIA.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREF OPTIONS FOR DISP ARE (1)RECYCLING, (2)INCIN
W/ENERGY RECOVERY, & (3) LANDFILL. HIGH FUEL VALUE OF PROD MAKES
OPTION 2 VERY DESIRABLE FOR MAT THAT CANNOT BE RECYCLED. TREATMENT
STOR, TRANSPORTATIO N & DISP MUST BE I/A/W APPLIC FED, STATE/
(SUPDAT)
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MIL-A-18001 ZINC
Preparer's Name:CHARLES GAVER
CAGE:70774
CAGE:70774
============= Composition/Information on Ingredients =============
Ingred Name:ZINC (SARA 313) (CERCLA)
CAS:7440-66-6
RTECS #:ZG8600000
> Wt:99.
Other REC Limits:5.0 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ALUMINUM (SARA 313)
CAS:7429-90-5
RTECS #:BD0330000
Minumum % Wt:.1
Maxumum % Wt:.5
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 DUST
ACGIH TLV:10 MG/M3 DUST; 9596
Ingred Name:ZINC OXIDE (SARA 313) (CERCLA)
CAS:1314-13-2
RTECS #:ZH4810000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9596
===================== Hazards Identification =====================
LD50 LC50 Mixture:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION-EXPOSURE MAY CAUSE
IRRITATION TO EYES, NOSE, THROAT & CAUSE A METALLIC TASTE IN MOUTH
(METAL FUME FEVER OR PRODUCE FLU LIKE SYMPTOMS). INGESTION-IS NOT
LIKELY. EYE-MECHAICAL IRRITATION POSS IBLE. SKIN-MAY CAUSE
DERMATITIS. NOTE: OVER HEATING OF ALLOY CAN PRODUCE METAL FUMES AND
OXIDES. MACHINING OPERATIONS SUCH AS GRINDING, SAWING, BUFFING CAN
GENERATE AIRBORNE PARTICULATE IN THE WORK AR EA.
Explanation of Carcinogenicity:ANY INGREDIENT LISTED AS CARCINOGENS
(NTP, IARC, OSHA)? NO
Effects of Overexposure:METAL FUME FEVER: MAY CAUSE COUGH, STOMACH
PAIN, HEADACHE, NAUSEA, VOMITING, METALLIC TASTE, CHILLS, FEVER,
PAIN IN THE MUSCLES AND JOINTS, THIRST, BRONCHITIS OR PENUMONIA AND
A BLUISH TINT TO THE SK IN. THESE SYMPTOMS GO AWAY IN 24-48 HOURS
AND LEAVE NO EFFETS.
Medical Cond Aggravated by Exposure:LUNG DISEASE.
======================= First Aid Measures =======================
First Aid:INHALATION-REMOVE FROM EXPOSURE TO FUME OR DUST. SEEK MEDICAL
HELP IF REQUIRED. INGESTION-INGESTION OF SIGNIFICANT AMOUNTS
UNLIKELY; SEEK MEDICAL HELP IF LARGE QUANTITIES ARE INGESTED. EYE-
FLUSH WITHWATER FOR AT LEAST 15 MINUTES. SEEK MEDICAL HELP IF
REQUIRED. SKIN-FLUSH THOROUGHLY WITH WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY POWDER, CARBON DIOXIDE EXTINGUISHER. DO NOT USE
WATER WILL REACT VIOLENTLY WITH ANY MOLTEN MATERIAL.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS TO
PROTECT AGAINST FUME.
Unusual Fire/Explosion Hazard:SMALL CHIPS, TURNINGS AND DUST WILL
IGNITE READILY. DUST CLOUDS MAY BE EXPLOSIVE.
================== Accidental Release Measures ==================
Spill Release Procedures:NON HAZARDOUS SOLID-NO SPECIAL PRECAUTIONS
REQUIRED FOR SPILLS OR BULK MATERIAL SCRAP METAL MAY HAVE RECYCLE
VALUE.
Neutralizing Agent:NO DATA PROVIDED BY RESPONSIBLE PARTY.
======================Handling and Storage ======================
Handling and Storage Precautions:WET MATERIAL SHOULD NEVER BE CHARGED
GRINDING, MACHINING OR BUFFING PRODUCT.
DUST/ FUME GENERATED. WASH HANDS THROUGHLY AFTER USE, ESPECIALLY
BEFORE EATING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR WHEN FUME OR DUST
PRESENT.
Ventilation:USE LOCAL EXHAUST VENTILATION FOR DUST/FUME.
Other Protective Equipment:FULL PROTECTIVE CLOTHING FOR DUST/FUMES.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
NO DATA PROVIDED BY RESPONSIBLE PARTY.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:=905.C, 1661.F
Melt/Freeze Pt:=419.4C, 787.F
Solubility in Water:INSOLUBLE
Appearance and Odor:SILVERY WHITE METALLIC, ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND HALOGENS.
Stability Condition to Avoid:STORAGE NEAR STRONG ACIDS AND HALOGENS.
Hazardous Decomposition Products:NO DATA PROVIDED BY RESPONSIBLE PARTY.
=================== Toxicological Information===================
Toxicological Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.
===================== Ecological Information =====================
Ecological:NO DATA PROVIDED BY RESPONSIBLE PARTY.
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW STATE AND LOCAL REGULATIONS REGARDING
DISPOSAL.
=================== MSDS Transport Information ===================
Transport Information:NOT REGULATED.
===================== Regulatory Information =====================
SARA Title III Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Federal Regulatory Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.
State Regulatory Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ARALDITE RD-2
Preparer's Name:DR JONAS WEISS
CAGE:02684
CAGE:02684
============= Composition/Information on Ingredients =============
Ingred Name:BUTANE, 1,4-BIS (2,3-EPOXYPROPOXY)-; (BUTANEDIOLDIGYCIDYL
EHTER)
CAS:2425-79-8
RTECS #:EJ5100000
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL RAT) 1410 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES:CORROSIVE. CAUSES BURNS.
SEVERE IRRITATION. OVEREXPOSURE EFFECTS:SEVERE IRRITATION,
DERMATITIS, SENSITIZATION. MUTAGENICITY:AMES TEST:POSITIVE. NUCLEUS
ANAMOLY (CHINESE MANSTER):POSITIVE. MO USE LYMPHOMA:POSITIVE WITH
AND WITHOUG ACTIVATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:ALLERGY, ECZEMA OR SKIN CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYE:IMMEDIATELY FLUSH EYES WITH WATER FOR AT LEAST 15
MINUTES. CALL MD. SKIN:PROMPTLY WASH WITH MILD SOAP AND WATER.
INGEST:IF CONSCIOUS, GIVE LARGE QUANTITIES OF WATER. GET MD.
INHAL:REMOVE TO FRESH AIR. GIVE OXYGEN IF NECESSARY.
PROMPTLYREMOVE WET CONTAMINATED NON-IMPERVIOUS CLOTHING. WASH
BEFORE REUSE.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:280F,138C
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:DECOMPOSITION AND COMBUSTION PRODUCTS MAY
BE TOXIC.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID ALL PERSONAL CONTACT. TAKE UP WITH
ABSORBENT MATERIAL. SHOVEL INTO CLOSABLE CONTAINERS. FLUSH
CONTAMINATED AREA WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DANGER:CORROSIVE. WILL CAUSE SEVERE
EYE AND SKIN IRRITATION. DO NOT GET ON SKIN, IN EYES OR ON
CLOTHING. DO NOT INHALE MIST OR VAPORS.
Other Precautions:KEEP CONTAINER TIGHTLY CLOSED WHEN NOT IN USE AND
DURING TRANSPORT. USE ONLY WITH ADEQUATE VENTILATION. WASH AFTER
HANDLING. FOR INDUSTRIAL USE ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR SUITABLE FOR
ORGANIC VAPORS, IF REQUIRED.
Ventilation:GOOD GENERAL MECHANICAL VENTILATION RECOMMENDED.
Other Protective Equipment:WEAR APPROPRIATE EQUIPMENT TO PVNT CONTACT
WITH EYES AND SKIN AND INHAL OF VAPS/MIST. EYE BATH AND SAFETY
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>392F,>200C
Vapor Pres:<0.002@20C
Spec Gravity:1.1
Appearance and Odor:CLEAR LIQUID, FAINT PLEASANT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS AND ALKALIES.
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
ALDEHYDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:5125 ULTRA-HIDE LATEX EGGSHELL ENAMEL
CAGE:01PD6
CAGE:72818
CAGE:01PD6
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 18-23%
Other REC Limits:NUISANCE PARTICULATE
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:PROPANOIC ACID, 2-METHYL, MONOESTER
W/2,2,4-TRIMETHYL-1,3-PENTANEDIOL, TEXANOL
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: 1-5%
Ingred Name:POLYDIMETHYL SILOXANE (LATEX), DIMETHICONE 350, LATEX
CAS:9016-00-6
RTECS #:TQ2690000
Fraction by Wt: 2-7%
Ingred Name:VINYL ACRYLIC RESIN
CAS:25067-01-0
Fraction by Wt: 14-19%
Ingred Name:WATER, H2O
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 34-39%
Ingred Name:ETHYLENE GLYCOL (SARA III)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 1-5%
Other REC Limits:10 MG/CUM
OSHA PEL:C 50 PPM
ACGIH TLV:C 50 PPM,VAPOR; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICON DIOXIDE
CAS:7631-86-9
RTECS #:VV3100000
Fraction by Wt: 14-19%
OSHA PEL:80 MG/CUM
ACGIH TLV:0.1 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: MUCOUS MEMBRANE
IRRITATION, DROWSINESS, DIZZINESS, LIGHTHEADEDNESS, & HEADACHE.
SKIN/EYES: IRRITATION. INGESTION: LARGE AMOUNTS COULD CAUSE SERIOUS
INJURY, ADVERSE HEALTH EFFECTS, KIDNEY D AMAGE OR FAILURE.
Explanation of Carcinogenicity:CRYSTALLINE SILICA IS A SUSPECTED HUMAN
CARCINOGEN.
Effects of Overexposure:INHALATION: MUCOUS MEMBRANE IRRITATION,
DROWSINESS, DIZZINESS, LIGHTHEADEDNESS, & HEADACHE. SKIN/EYES:
IRRITATION. INGESTION: LARGE AMOUNTS COULD CAUSE SERIOUS INJURY,
ADVERSE HEALTH EFFECTS, KIDNEY D AMAGE OR FAILURE.
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN,
RESPIRATORY, LUNG, & KIDNEY DISORDERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR OR OXYGEN IF
NEEDED. SKIN: WASH W/PLENTY OF WATER, THEN SOAP & WATER. EYES:
FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS. INGESTION: OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:>200F
Extinguishing Media:DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:WATER MAY BE USED TO COOL & PROTECT EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY BURST IF EXPOSED TO
EXTREME HEAT OR FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:COMPLY W/ALL APPLICABLE HEALTH & ENVIRONMENTAL
REGULATIONS. VENTILATE AREA. COLLECT W/ABSORBENT MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE <100F. KEEP FROM FREEZING. USE
ONLY W/ADEQUATE VENTILATION. KEEP CONTAINERS TIGHTLY CLOSED &
UPRIGHT WHEN NOT IN USE. DON'T TAKE INTERNALLY.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID CONTACT W/SKIN,
EYES, & BREATHING VAPORS. IF SANDING IS DONE, WEAR A DUST MASK TO
AVOID BREATHING OF SANDING DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR. WEAR A DUST
MASK, IF SANDING.
Ventilation:PROVIDE MECHANICAL/LOCAL EXHAUST VENTILATION TO PREVENT
BUILD-UP OF VAPORS.
Other Protective Equipment:EYE WASH, SAFETY SHOWER
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS THOROUGHLY AFTER HANDLING, BEFORE EATING, OR
SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text: 212F
Appearance and Odor:LIQUID
Percent Volatiles by Volume:56.1%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS,
Stability Condition to Avoid:ELEVATED TEMPERATURES >100F, FREEZING
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CONTAX NONFLAMMABLE, 91020
Preparer's Name:MLH
CAGE:JO103
CAGE:18399
CAGE:JO103
============= Composition/Information on Ingredients =============
Ingred Name:ETHANE, 1,1-DICHLORO-1-FLUORO-;
(1,1-DICHLORO-1-FLUOROETHANE) (SARA 313)
CAS:1717-00-6
RTECS #:KI0997000
Fraction by Wt: 97%
OSHA PEL:N/K
ACGIH TLV:N/K
Ozone Depleting Chemical:2
Ingred Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: 3%
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM; 30000STEL
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE EYE & SKIN IRRITATION.
EXCESS INHAL OF VAPORS MAY CAUSE RESP IRRIT, DIZZINESS, GIDDINESS &
NAUSEA. MISUSE OR DELIBERATE INHALATION MAY BE HARMFUL OR FATAL.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE: IMMED FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS &
CALL MD. SKIN: WASH THORO W/PLENTH OF WATER & SOAP. INHAL: MOVE TO
FRESH AIR. ADMIN O*2 & CALL MD. INGEST: ACCIDENTAL INGESTION IS
UNLIKELY FR OM AN AEROSOL. IF INGESTED, CALL MD IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F,>93C
Lower Limits:7.6%
Upper Limits:17.7%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:EXPOSURE TO FIRE, HEAT OR PROLONGED
SUNLIGHT MAY CAUSE BURSTING. CONTACT W/FLAME OR HOT SURFACES MAY
PRODUCE TOXIC GASES.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE
AREA. WEAR NIOSH/MSHA APPRVD RESP PROT. CONTAIN & PICK UP
MATERIALS. PUT IN SEALED APPROVED CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE ONLY IN WELL VENTED AREAS. AVOID
PRLNGD BRTHG OF VAP/SPRAY MIST. AVOID CONT W/EYES, SKIN & CLTHG. DO
NOT PUNCTURE, INCIN, BURN/STORE CNTNRS >0F.
Other Precautions:EXPOS TO FIRE, HEAT OR PRLNGD SUNLIGHT MAY CAUSE
BURSTING. DO NOT TAKE INTERNALLY. IN CASE OF ACCIDENT/ILLNESS, SEEK
MD IMMED, SHOW LABEL/MSDS. KEEP OUT OF REACH OF CHILDREN. ALWAYS
READ & FOLLOW DIRE CTIONS ON PROD LABEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION IS INADEQUATE, WEAR NIOSH/MSHA
APPROVED RESPIRATORY EQUIPMENT.
Ventilation:LOCAL EXHST: REQUIRED. MECH(GENL): REQUIRED.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:<0F,<-18C
Vapor Density:HVR/AIR
Spec Gravity:1.23
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:CLEAR LIQUID AEROSOL.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:AVOID EXPOSURE TO FIRE, HEAT, OR PROLONGED
SUNLIGHT.
Hazardous Decomposition Products:CO, CO*2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTES IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS. DO NOT PUNCTURE, INCINERATE OR BURN
CONTAINERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:135 2004 EKTACHEM ISO-ENZYME CALIBRATOR KIT
Kit Part:Y
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:BOVINE ALBUMIN/BOVINE SERUM ALBUMIN-BASED LYOPHILATE
CAS:9048-46-8
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS UNKNOWN.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY
& GI TRACTS. ACUTE- EYES/SKIN/INHALATION/INGESTION:CONTACT MAY
SERVE AS A ROUTE OF INFECTION. LOW HAZARD FOR RECOMMENDED HANDLING
BY TRAINED PERSONNEL. ANY BLOOD OR BLOOD-DERIVED PRODUCT SHOULD BE
CONSIDERED TO HAVE POTENTIAL TO CAUSE DISEASE. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NONE FOR TRAINED PERSONNEL.
======================= First Aid Measures =======================
First Aid:IN CASE OF CONTACT WITH EYE, MOUTH, OTHER MUCOUS MEMBRANE,
NON-INTACT SKIN OR PARENTERAL CONTACT, REPORT INCIDENT TO
SUPERVISOR AND/OR MEDICAL DEPARTMENT OF EMPLOYER IN ACCORDANCE WITH
29 CFR 1910.103 0 (FINAL RULE)- BLOODBORNE PATHOGENE-NOVEMBER 22,
1991. INHALED:MOVE TO FRESH AIR. EYES/SKIN:FLUSH WITH WATER FOR 15
MINUTES. THEN WASH SKIN WITH SOAP & WATER. ORAL:RINSE MOUTH WITH
WATER.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL.
USE WATER SPRAY TO COOL FIRE EXPOSED CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. HAZARDOUS DECOMPOSITION
PRODUCTS MAY BE FORMED.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:DISINFECT WITH A 5.25% SODIUM HYPOCHLORITE
SOLUTION (HOUSEHOLD BLEACH) DILUTED WITH 9 PARTS WATER & LEAVE
UNDISTURBED FOR AT LEAST 30 MINUTES. ABSORB SPILL WITH VERMICULITE
& TRANSFER TO PROPER CONTAI NER FOR DISPOSAL. CLEAN SURFACE
THOROUGHLY.
Neutralizing Agent:1 PART OF 5.25% SODIUM HYPOCHLORITE SOLUTION
(HOUSEHOLD BLEACH) + 9 PARTS WATER
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. STORE AT OR
BELOW -18C (0F). HANDLE AS IF POTENTIALLY INFECTIOUS AND FOLLOW
UNIVERSAL PRECAUTIONS.
Other Precautions:MINIMIZE DUST GENERATION AND ACCUMULATION. USE WITH
ADEQUATE VENTILATION. AVOID BREATHING DUST. AVOID CONTACT WITH
EYES, SKIN AND CLOTHING. WASH THOROUGHLY WITH SOAP AND WATER. KEEP
OUT OF REACH OF CH ILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:NORMAL GOOD GENERAL ROOM VENTILATION SHOULD BE SUFFICIENT.
Other Protective Equipment:EYE WASH STATION, QUICK DRENCH SHOWER AND
IMPERVIOUS CLOTHING OR LAB COAT
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
KEY1:K1. OSHA FINAL RULE 29 CFR 1910.1030 IS A PERFORMANCE STANDARD.
THE RULE REQUIRES A WRITTEN EXPOSURE CONTROL PLAN, A HEPATITIS B
IMMUNIZATION PROGRAM, A POST-EXPOSURE TREATMENT, EVALUATION PROGRA
M & AN EMPLOYEE TRAINING PROGRAM. EACH UNIT WAS TESTED & DETERMINED
TO BE NEGATIVE FOR HEPATITIS B & ANTIBODY TO HIV.
================== Physical/Chemical Properties ==================
HCC:K1
NRC/State Lic Num:NOT RELEVANT
Solubility in Water:APPRECIABLE
Appearance and Odor:TAN, YELLOW SOLID - ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN, OXIDES OF SULFUR
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE OR LOCAL LAWS. INCINERATE. CONTRACT WITH A
LICENSED CHEMICAL DISPOSAL AGENCY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:R-614 PHENOLPHTHALEIN INDICATOR SOLUTION
CAGE:OAFT1
CAGE:94525
CAGE:OAFT1
============= Composition/Information on Ingredients =============
Ingred Name:PHENOLPHTHALEIN
CAS:77-09-8
RTECS #:SM8380000
Fraction by Wt: 1%
Ingred Name:METHANOL (METHYL ALCOHOL), COLUMBIAN SPIRITS
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 99%
Other REC Limits:200 PPM
OSHA PEL:260 MG/CUM
ACGIH TLV:262 MG/CUM (SKIN)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION. INGESTION: MAY
CAUSE BLINDNESS/DEATH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/WATER FOR 15 MINS. INHALATION: REMOVE TO
FRESH AIR. INGESTION: INDUCE VOMITING. DILUTE BY GIVING PLENTY OF
WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:54F
Lower Limits:6
Upper Limits:36.5
Extinguishing Media:WATER, ALCOHOL FOAM, DRY CHEMICAL
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:ABOSRB W/VERMICULITE/SIMILAR ABSORBENT, SWEEP
UP & PLACE IN DRY GARBAGE; FLUSH TO SEWER/GROUND W/PLENTY OF WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY AREA AWAY FROM ANY
REACTIVE MATERIALS/CHEMICALS.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:RUBBER APRON.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:64.8F
Vapor Pres:100
Vapor Density:1.11
Spec Gravity:0.78
Evaporation Rate & Reference:(WATER=1): 1
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT STRAW COLORED LIQUID W/SWEET ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS/ANY REACTIVE MATERIALS.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:GF 1200 SERIES FLUXES GF-1225
CAGE:73766
CAGE:73766
CAGE:84311
============= Composition/Information on Ingredients =============
Ingred Name:ROSIN ACID *94-3*
CAS:8050-09-7
Fraction by Wt: 10-50%
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 38-69%
Other REC Limits:400 PPM
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
Ingred Name:ISOBUTANOL/2-METHYL-1-PROPANOL/ISOBUTYL ALCOHOL
CAS:78-83-1
RTECS #:NP9625000
Fraction by Wt: 5-9%
Other REC Limits:50 PPM
OSHA PEL:50 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:NAPHTHA PETROLEUM, HEAVY ALKYLATE C9-C12 BOILING PT
302-428F *94-3*
CAS:64741-65-7
Fraction by Wt: 7-12%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT MAY CAUSE IRRITATION.
PROLONGED/REPEATED CONTACT MAY CAUSE TISSUE DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:HEADACHE, DIZZINESS, DIFFICULTY BREATHING,
NAUSEA, VOMITING, REDNESS, BURNING, RASH, DRYNESS, TEARING, BLURRED
VISION, IRRITAITON.
Medical Cond Aggravated by Exposure:SKIN ALLERGIES & RESPIRATORY/LUNG
CONDITIONS.
======================= First Aid Measures =======================
First Aid:SKIN: FLUSH W/WATER IMMEDIATELY. WASH THOROUGHLY & APPLY
LOTION. EYES: FLUSH W/WATER FOR 15 MINS. INGESTION: DRINK LARGE
AMOUNTS OF WATER. NEVER GIVE LIQUIDS TO AN UNCONSCIOUS PERSON.
INHALATION: REMO VE TO FRESH AIR. SUPPORT RESPIRATION IFREQUIRED.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:53F
Lower Limits:2
Upper Limits:12
Extinguishing Media:ALCOHOL FOAM, DRY CHEMICAL, CO2
Fire Fighting Procedures:USE SCBA. FLAMMABLE LIQUID, WATER MAY SPREAD
FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF FLAME/IGNITION. FLUSH
INTO A CHEMICAL SEWER/SOAK UP W/A SUITABLE ABSORBANT.
======================Handling and Storage ======================
Handling and Storage Precautions:GROUND METALLIC CONTAINERS.
Other Precautions:AVOID CONTACT AS MUCH AS POSSIBLE. NO SMOKING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR ORGANIC VAPOR MASK FOR FUMES > TLV, DURING
SOLDERING.
Ventilation:LOCAL EXHAUST PREFERRED. MECHANICAL: OK
Other Protective Equipment:AS REQUIRED TO MINIMIZE CONTACT.
Work Hygienic Practices:WASH AFTER USE. FOLLOW GOOD INDUSTRIAL HYGIENIC
PRACTICES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:181F
Melt/Freeze Pt:M.P/F.P Text:-127F
Vapor Pres:33
Vapor Density:2.7
Spec Gravity:0.83-0.92
Evaporation Rate & Reference:(BU AC=1): 1.7
Solubility in Water: 65
Appearance and Odor:AMBER LIQUID W/ALCOHOL ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
Stability Condition to Avoid:FLAME, IGNITION SOURCES
Hazardous Decomposition Products:CO, CO2, HYDROCARBONS
==================== Disposal Considerations ====================
Waste Disposal Methods:RECLAMATION/INCINERATION SUGGESTED. ALWAYS
DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS. FLAMMABLE LIQUID
UN1219.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:RINSE AWAY
CAGE:31285
CAGE:31285
============= Composition/Information on Ingredients =============
Ingred Name:INORGANIC PHOSPHATE SALT
Fraction by Wt: MINOR
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:NONE SPECIFIED BY MANUFACTURER.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>200F,>93C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES.
LAUNDER CONTAMINATED CLOTHING BEFORE WEARING. KEEP WORK AREA CLEAN.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL REGULATIONS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:VF-180 SCREEN INK THINNER
CAGE:FO883
CAGE:FO883
CAGE:76708
============= Composition/Information on Ingredients =============
Ingred Name:ISOPHORONE; 3,3,5 TRIMETHYL 2-CYCLOHEXENE 1-ONE
CAS:78-59-1
RTECS #:GW7700000
Fraction by Wt: 25%
Other REC Limits:5 PPM
OSHA PEL:140 MG/CUM
ACGIH TLV:C 28 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:DIACETONE ALCOHOL
CAS:123-42-2
RTECS #:SA9100000
Fraction by Wt: 25%
Other REC Limits:50 PPM
OSHA PEL:240 MG/CUM
ACGIH TLV:238 MG/CUM
Ingred Name:SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC, HIGH FLASH
AROMATIC NAPHTHA
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 50%
Ingred Name:VOL ORGANIC CMPD: 7.4 LBS/GAL OR 880 G/L
RTECS #:9999999VO
Ingred Name:WEIGHT PER GALLON IN POUNDS: 7.4 LBS
RTECS #:9999999WG
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: BURNING. SKIN: IRRITATION,
ABSORPTION. INHALATION: RESPIRATORY TRACT IRRITATION. INGEST: GI
TRACT IRRITATION. NERVOUS SYSTEM DEPRESSION, HARMFUL/FATAL.
REPEATED/PROLONGED OVEREXPOSURE BY INHALAT ION/SKIN ABSORPTION MAY
CAUSE BLOOD DISORDERS. OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT
BRAIN/NERVOUS SYSTEM DAMAGE.
Effects of Overexposure:EYES: TEARING, REDNESS. SKIN: DRYNESS,
CHAPPING, REDNESS.
Medical Cond Aggravated by Exposure:SKIN & LUNG DISORDERS
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/WATER FOR 15 MINS.
INHALATION: REMOVE TO FRESH AIR, RESTORE BREATHING. INGESTION:
CONTACT A PHYSICIAN IMMEDIATELY. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:110F
Lower Limits:0.8%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER SPRAY
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE, BUT MAY BE
USED TO COOL CONTAINERS. USE SCBA.
Unusual Fire/Explosion Hazard:CLOSED CONTAINER MAY EXPLODE WHEN EXPOSED
TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
BREATHING VAPORS. CONTAIN RELEASE: REMOVE W/INERT ABSORBENT &
NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS IN COOL,
DRY, WELL VENTILATED AREA AWAY FROM IGNITION SOURCES. KEEP
CONTAINERS CLOSED WHEN NOT IN USE.
Other Precautions:SMOKE IN DESIGNATED AREA ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VAPOR CONCENTRATION IS >TLV, USE NIOSH
APPROVED RESPIRATORY W/ORGANIC CHEMICAL CARTRIDGE. CONSULT A
REPUTABLE SAFETY SUPPLY COMPANY FOR PROPER RESPIRATORY SELECTION.
Ventilation:AS REQUIRED
Other Protective Equipment:SOLVENT RESISTANT APRON, EYE WASH
Work Hygienic Practices:WASH W/SOAP/WATER BEFORE EATING, SMOKING. OR
USING TOLIET FACILITIES. REMOVE/LAUNDER CONTAMINATED CLOTHING
BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:313-420F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, IGNTION SOURCES
Hazardous Decomposition Products:CO, CO2, OTHER NOXIOUS GASES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W LOCAL, STATE & FEDERAL
REGUALTIONS. EMPTY CONTAINERS SHOULD BE DISPOSED OF IN AN
ENVIRONMENTALLY SAFE MANNER.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:33 EXTREME LOW TEMP BEARING GREASE, MEDIUM (SEE SUPP)
Resp. Party Other MSDS Num.:1889788
CAGE:5D028
CAGE:5D028
Contract Num:SP0450-00-M-C517
CAGE:0PGK2
============= Composition/Information on Ingredients =============
Ingred Name:LITHIUM STEARATE
CAS:4485-12-5
RTECS #:WI4370000
= Wt:25.
ACGIH TLV:10 MG/M3 (STEARATE)
Ingred Name:2,6-CIS-DIPHENYLHEXAMETHYLCYCLOTETRASILOXANE
CAS:33204-76-1
RTECS #:GZ4390000
< Wt:.1
Other REC Limits:20 UGM/M3 (DOW)
Ingred Name:PHENYLHEPTAMETHYLCYCLOTETRASILOXANE
CAS:10448-09-6
RTECS #:GZ4392000
< Wt:.1
Other REC Limits:200 UGM/M3 (DOW)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: DIRECT EYE CONTACT MAY CAUSE
TEMPORARY DISCOMFORT WITH MILD REDNESS AND DRYNESS SIMILAR TO
WINDBURN. SKIN: A SINGLE RELATIVELY SHORT EXPOSURE CAUSES NO KNOWN
ADVERSE EFFECT. SEVERAL REPEATED OR P ROLONGED EXPOSURES (24-48
HRS) MAY IRRITATE. INHALATION: NO IRRITATION TO EYES AND
RESPIRATORY PASSAGES. NO INJURY IS LIKELY FROM RELATIVELY SHORT
EXPOSURES OF LESS THAN 8 HOURS. ORAL: SMALL AMOUNTS T RANSFERRED TO
THE MOUTH BY FINGERS DURING USE. ETC., SHOULD NOT INJURE.
SWALLOWEING LARGE AMOUNT MAY INJURE SLIGHTLY.
Explanation of Carcinogenicity:NONE KNOWN.
Effects of Overexposure:DISCOMFORT, REDNESS, DRYNESS
Medical Cond Aggravated by Exposure:NO DATA PROVIDED BY RESPONSIBLE
PARTY.
======================= First Aid Measures =======================
First Aid:EYE: IMMEDIATELY FLUSH WITH WATER. SKIN: NO FIRST AID SHOULD
BE NEEDED. INHALATON: NO FIRST AID SHOULD BE NEEDED. ORAL: GET
MEDICAL ATTENTION. COMMENTS: TREAT ACCORDING TO PERSON'S CONDITION
AND SPECI FICS OF EXPOSURE.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:=101.1C, 214.F
Autoignition Temp:Autoignition Temp Text:N/D
Lower Limits:N/D
Upper Limits:N/D
Extinguishing Media:WATER, WATER FOG (OR SPRAY), CARBON DIOXIDE, DRY
CHEMICAL, FOAM.
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING SHOULD BE WORN IN FIGHTING FIRES INVOLVING
CHEMICALS.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:MOP UP, OR WIPE UP, OR SOAK UP WITH ABSORBENT
AND CONTAIN FOR SALVAGE OR DISPOSAL. CLEAN ANY REMAINING SLIPPERY
SURFACES BY APPROPRIATE TECHNIQUES SUCH AS: SEVERAL MOPPINGS OR
SWABBINGS WITH APPROPRIA TE SOLVENTS; WASHING WITH MILD, CAUSTIC
DETERGENTS OR SOLUTIONS; OR HIGH PRESSURE STEAM FOR LARGE AREAS.
FOR NONSILICONES, USE TYPICAL INDUSTRIAL CLEANING MATERIALS.
Neutralizing Agent:NO DATA PROVIDED BY RESPONSIBLE PARTY.
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL PRECAUTIONS. USE REASONABLE
CARE.
Other Precautions:NO DATA PROVIDED BY RESPONSIBLE PARTY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GENERAL VENTILATION RECOMMENDED.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASHING AT MEALTIME AND END OF SHIFT IS
ADEQUATE.
Supplemental Safety and Health
AVOID EYE CONTACT. DO NOT TAKE INTERNALLY. THESE PRECAUTIONS ARE FOR
ROOM TEMPERATURE HANDLING. USE AT ELEVATED TEMPERATURE OR
AEROSOL/SPRAY APPLICATIONS, MAY REQUIRE ADDED PRECAUTIONS. SDB P/N:
MOLYK OTE 33 MEDIUM.
================== Physical/Chemical Properties ==================
HCC:V5
Melt/Freeze Pt:M.P/F.P Text:N/D
Spec Gravity:1.10 @ 25C
Solubility in Water:NONE.
Appearance and Odor:BEIGE GREASE; SLIGHT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL CAN CAUSE A REACTION.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CARBON OXIDES AND TRACES OF
INCOMPLETELY BURNED CARBON COMPOUNDS, SILICON DIOXIDE, METAL
OXIDES. FORMALDEHYDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:COMPLETE INFORMATION NOT YET AVAILABLE.
===================== Ecological Information =====================
Ecological:COMPLETE INFORMATION NOT YET AVAILABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL OF COLLECTED PRODUCT, RESIDUES, AND
CLEANUP MATERIALS MAY BE GOVERNMENTALLY REGULATED. OBSERVE ALL
APPLICABLE LOCAL, STATE, AND FEDERAL WASTE MANAGEMENT REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:US DOT INFORMATION (49 CFR 172.101): PROPER
SHIPPING NAME: NOT APPLICABLE. HAZARD TECHNICAL NAME: NOT
APPLICABLE. HAZARD CLASS: NOT APPLICABLE. UN/NA NUMBER: NOT
APPLICABLE. PACKING GROUP: NOT APPLICA BLE.
===================== Regulatory Information =====================
SARA Title III Information:SECTION 302 EXTREMELY HAZARDOUS SUBSTANCES:
NONE. SECTION 304 CERCLA HAZARDOUS SUBSTANCES: NONE. SECTION 312
HAZARD CLASS: ACUTE: YES; CHRONIC: YES; FIRE: NO; PRESSURE: NO;
REACTIVE: NO. SECTION 313 T OXIC CHEMICALS: NONE PRESENT OR NONE
PRESENT IN REGULATED QUANTITIES.
Federal Regulatory Information:CONTENTS OF THIS MSDS COMPLY WITH THE
OSHA HAZARD COMMUNICATION STANDARD 29 CFR 1910.1200. TSCA STATUS:
ALL CHEMICAL SUBSTANCES FOUND IN THIS PRODUCT COMPLY WITH THE TOXIC
SUBSTANCES CONTROL ACT INVEN TORY REPORTING REQUIREMENTS.
State Regulatory Information:CALIFORNIA PROPOSITION 65: WARNING: THIS
PRODUCT CONTAINS THE FOLLOWING CHEMICAL(S) LISTED BY THE STATE OF
CALIFORNIA UNDER THE SAFE DRINKING WATER AND TOXIC ENFORCEMENT
ACT OF 1986 (PROPOSITION65) AS BEING KNOWN TO CAUSE CANCER OR
BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM: NONE KNOWN.
MASSACHUSETTS: NO INGREDIENT REGULATED BY THE MA RIGHT-TO-KNOW LAW.
NEW JERSEY: DIMETHYL, PHENYLMETHYLSILOX ANE, TRIMETHYL-TERMINATED,
CAS# 63148-52-7, 75%; LITHIUM STEARATE, CAS# 4485-12-5, 25%.
PENNSYLVANIA : DIMETHYL, PHENYLMETHYLSILOXANE,
TRIMETHYL-TERMINATED, CAS# 63148-52-7, 75%; LITHIUM STEARATE, CAS#
4485-12-5, 25%.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SODIUM DICHROMATE DIHYDRATE
CAGE:AMCHC
CAGE:AMCHC
CAGE:ACHR0
CAGE:0YED2
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM BICHROMATE (SARA 313) (CERCLA)
CAS:10588-01-9
RTECS #:HX7700000
Fraction by Wt: 88%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 0.1 MG (CRO3)/M3
ACGIH TLV:0.05 MG(CR)/M3;A1;96
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 12%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT,BOTH SEXES) 51MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL:DUST/MIST CAN CAUSE DMG TO MUC
MEMB,PERFORATION OF NASAL SEPTUM,IRRIT RESP SYS.CAN CAUSE
RASH,CONTACT W/BROKEN SKIN MAY CAUSE EXTERNAL ULCERS,"CHROME
SORES".CAN BE ABSORBED THRU SKIN & CAUSE SYS POISONING.INGEST ALSO
CAUSE SYS POISONING.
Explanation of Carcinogenicity:PER MSDS:HEXAVELENT CHROMIUM CMPD GROUP
OF CHEM LISTED AS BEING SUFFICIENT EVIDENCE FOR CARCI TO
HUMANS/ANIMALS.
Effects of Overexposure:DMG TO MUCOUS MEMBRANE, PERFORATION OF NASAL
SEPTUM, IRRIT RESP SYSTEM. RASH, BROKEN SKIN MAY CAUSE ULCERS
(CHROME SORES) SYSTEM POISONING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN/EYE CONTACT:FLUSH IMMED W/WATER(SOAP/WATER FOR SKIN)FOR
@LEAST 15MINS WHILE REMOVING CONTAMIN CLOTH/SHOES.ASCORBIC ACID IS
REPORTED TO BE USEFUL ANTIDOTE FOR CHROMIUM POISONING. INHAL:REMOVE
TO F RESH AIR.BREATH STOP GIVE MOUTH-TO-MOUTH RESUSC.SEEK MED ATTN
IMMED. INGEST:NEVER GIVE ANYTHING BY MOUTH IF UNCONSC.DO NOT INDUCE
VOMIT.GIVE LG QUANT OF WATER OR MILK IF AVAILABLE. IF VOMITING
OCURRS SPONT KEEP AIRWAY CLEAR/GIVE MORE H2O. GET MED ATTN IMMED.
VICTIMS SHOULD BE GIVEN 5-10G ASCORBIC ACID (DISSOLVED IN H2O).
SKIN ULCERS-REMOVE FRM EXPO,CLEAN/DEBRIDE DAILY, APPLY ANTIBIOTIC
CREAM/DRESS ING DAILY.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Autoignition Temp:Autoignition Temp Text:NP
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:THIS PRODUCT NOT FLAMM. CHOICE OF EXTINGUISHING
MEDIA SHOULD B EBASED ON OTHER MATLS INVOLVED IN THE FIRE.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:PRODUCT NOT FLAMM. PROD MAY ACT AS
OXIDIZING AGENTS TO SUSTAIN FIRE INVOLVING ORGANIC MATTER OR OTHER
EASILY OXIDIZABLE MATL.
================== Accidental Release Measures ==================
Spill Release Procedures:CAREFULLY SHOVEL/SWEEP INTO CLSD METAL CNTNR
FOR RECLAMATION/DISPO.SPILLED LIQ SHOULD BE CONTAIN/ABSOR W/INERT
ABSORBENT(VERMICULITE,SAND,SOIL).SHOVEL/SWEPT INTO CLSD METAL
CNTNR.ALL VISIBLE SPILL MAT L MUST BE REMOVED.RQ:10 LBS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:HNDLG WEAR SPEC PROT EQPMT IN
MSDS.WEAR RESP PROT IN EVENT WEHRE EXPO >OSHA PEL.KEEP CNTNR CLSD
WHEN NOT IN USE.STORE AWAY FROM COMBUST/OTHER CHEM.
Other Precautions:DON'T RECYLCE/REUSE CNTNR.DISPO OF EMPTY CNTNR IAW
LOC/STATE/FED REGS.KEEP SEPARATED FROM FOOD PRODUCTS.DON'T GET IN
EYE/SKIN/CLOTH.DISPO:ADJUST PH TO 8.5 W/SODA ASH TO PPT TRIVALENT
CR AS CR(OH)3.FIL TER/DRY PPT,DISPO IAW LOC/STATE/FED REGS
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MSHA/NIOSH APPROVED FILTER-TYPE DUST RESPIRATOR
USED IN ACCORDANCE WITH REQMTS OF 29 CFR 1910.134.
Ventilation:SUFFICIENT TO MAINTAIN WORKPLACE CONCENTRATION BELOW
TLV.USE ONLY W/VENTI SUFFI TO LIMIT WORKER EXPO.
Other Protective Equipment:RUBB BOOTS,LONG-SLEEVE SHIRT,HARD HAT ARE
RECOMMENDED.AVAILABILITY FO SAF SHOWER & EYEWASH FOUNTAIN IS
RECOMMENDED.
Work Hygienic Practices:CLEAN WELL CONTAM CLOTH/SHOES BEF REUSE OR
DISCARD.AVOID BREATH DUST/SOLN MIST.TAKE SHOWER DAILY AFT WORK
W/LOTS OF SOAP
Supplemental Safety and Health
PH:3.6-4.4 @25C 400G/L. HCC = D2 ASSIGNED BASED UPON THE FACT THAT ITEM
IS AN OXIDIZER AND TOXIC, ALSO HAS ACUTE & CHRONIC HEALTH EFFECTS
(SEE TABLE B-3 OF DLAI 4145.11).
================== Physical/Chemical Properties ==================
HCC:D2
Boiling Pt:B.P. Text:NP
Melt/Freeze Pt:M.P/F.P Text:NP
Decomp Temp:Decomp Text:752F,400C
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:D
pH:SUPPLE
Viscosity:NP
Evaporation Rate & Reference:NA
Solubility in Water:73, APPRECIABLE.
Appearance and Odor:RED-ORANGE CRYSTALS, NO ODOR.
Percent Volatiles by Volume:NA
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY REACTR W/EASILY OXIDIZABLE/COMBUST MATLS ESPECIALLY @ELEVATED
TEMPS.MAY REACT W/STRONG ALKALIS/ACIDS TO GIVE HEAT.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:THERM DECOMP MAY PRODUCE CHROMIC
OXIDE(CR2O3) OR OTHER OXIDES OF CHROMIUM WHICH MAY BE
HAZARDOUS.NAOH/NA2O ALSO PRODUCE.
==================== Disposal Considerations ====================
Waste Disposal Methods:D007.DON'T DISCHARGE INTO SEWER/NAVIG H2O/CONTA
UNDERGROUND H2O SOURCES.WASTE RECLAIM IF POSSIBLE;IF NOT CONTACT
LOC WASTE DISPO CONTRACTOR OR:DISSOLVE IN LOTS OF H2O,ADD H2SO4
SOLN PH2.5.REDUCE TO TR IVALENT CR W/REDUCE AGENT(IRON SULFATE)(OTH
PRECA)
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: 60212, BONDTITE XL MICROCEL LIGHT 15 LB (SUPP DATA)
Cage: 53472
Box: 35906
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 53472
Box: 35906
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: YES
OSHA: NO
Effects of Exposure: INHAL:MAY CAUSE IRRIT TO MUC MEMB, RESP SYS, NOSE, EYES
& THROAT, INCR NASAL MUC SECRETION, METALLIC TASTE, DROW, VERTIGO, SLIGHT
MUSCULAR WEAK ACCOMPANIED BY INERTIA & DEPRESS, NAUS, VOMIT, LOSS OF A
PPETITE & GEN WEAK. SKIN:PRLNG CONT MAYCAUSE DRYING, CRACKING, ITCH,
BURNING & SORES. ABSORPTION IS (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: SEE LR VERSIONFOR ADDITIONAL INFO (FP N).
Signs And Symptions Of Overexposure: HLTH HAZ:MOD. EYE:CONT MAY CAUSE SEV ITCH,
TEARING & POSS OCULAR DMG. VAPS MAY BE IRRIT. INGEST:NO KNOWN RPTS FOUND,
BUT MAY RSLT IN SYMPS DESCRIBED UNDER INHAL. TARGET ORGS:REPRO:STYRENE HAS
BEEN OBS ERVED TO PASS PLACENTA & SOME NERV SYS DEFECTS WERE OBSERVED IN
CHILDREN WHOSE MOTHERS HAD BEEN EXPOS DURING (SUPDAT)
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: SKIN:FLUSH W/WATER THEN WASH THORO W/SOAP & WATER. REMOVE CONTAM
CLTHG & WASH BEFORE REUSE. CALL POIS CTL CTR/MD IF IRRIT PERSISTS.
EYES:FLUSH W/WATER FOR AT LST 15 MINS & CALL POIS CTL CTR/MD IF IRRI T
PERSISTS. INHAL:MOVE TO FRESH AIR. IFBRTHG IS DFCLT, GIVE OXYGEN. IF NOT
BRTHG, GIVE ARTF RESP. KEEP VICTIM QUIET & WARM. CALL POIS CTL CTR/MD
IMMED. INGEST:DRINK WATER. DO NOT INDUCE (SUPP DATA)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: VENTILATE AREA, STOP LEAK IF IT CAN BE DONE W/OUT
RISK. TAKE UP W/SAND, EARTH OR OTHER ABSORBING MATERIAL & PLACE IN A
CLEAN, DRY, LEAK-PROOF CONTAINER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF ACCORDING TO LOCAL, STATE & FEDERAL
REGULATIONS.
Handling And Storage Precautions: STORE IN COOL, DRY AREA. AVOID EXCESSIVE
HEAT. AVOID EYE & SKIN CONTACT.
Other Precautions: DO NOT STORE IN DIRECT SUNLIGHT OR EXCESSIVE HEAT. FLAMMABLE
MATERIAL. IRRITANT. SKIN/EYE HAZARD. TOXIC AGENT. REPRODUCTIVE TOXIN, NERVOUS
SYSTEM TOXIN, LUNG TOXIN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point Text: 90F,32.2C +/- 2
Extinguishing Media: USE DRY CHEMICAL, CO*2, WATER OR FOAM EXTINGUISHER FOR
SMALL FIRES.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). FOR LARGE FIRES, EVACUATE AREA & CALL FIRE DEPARTMENT.
Unusual Fire/Explosion Hazard: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH/MSHA APPROVED CANISTER OR AIR-PACK (SELF
CONTAINED AIR SUPPLY) RESPIRATOR.
Ventilation: GENERAL MECHANICAL: USE HOOD TO LOWER TLV & PEL TO ACCEPTABLE
UNITS. LOCAL EXHAUST: OPEN DOORS & WINDOWS.
Other Protective Equipment: ANSI APPROVED EMERGENCY EYE WASH & DELUGE SHOWER
(FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: NOTE:USER'S OF "L" VERSION SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). MFR'S TRADE NAME/PART NO:DISPENSER BAG. %
VOLAT:17.5 +/- 1. EFTS OF OVEREXP:PREGNANCY. EYE, SKIN, CNS, LUNG. FIRST AID
PRO C:VOMIT. CALL POIS CTL CTR/MD IMMED. AVOID ALCOHOLIC BEVERAGES. NEVER
GIVE ANYTHING BY MOUTH TO UNCON PERSON.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >300F,>149C
Vapor Pres: 5.2 @ 25C
Vapor Density: 3.6
Spec Gravity: 1.08 +/- 0.01
Solubility in Water: INSOLUBLE
Appearance and Odor: BEIGE/WHITE PASTE; SWEET, ACRID ODOR.
Percent Volatiles by Volume: SUPDAT
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: EXPOSURE TO EXCESSIVE HEAT, OPEN FLAME OR SPARKS.
Materials To Avoid: ORGANIC PEROXIDES.
Hazardous Decomposition Products: CO, CO*2, LOW MOLECULAR WEIGHT HYDROCARBONS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: 60212, BONDTITE XL MICROCEL LIGHT 15 LB (SUPP DATA)
Cage: 53472
Company Name: OATEY CO
Street: 4700 WEST 160TH STREET
PO Box: 35906
Zipcode: 44135
Label Required IND: Y
Date Of Label Review: 02/01/1994
Status Code: C
Label Date: 02/01/1994
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE. ACUTE:INHAL:MAY CAUSE IRRITATION TO MUCOUS
MEMBRANES, RESPIRATORY SYSTEM, NOSE, EYES & THROAT, INCREASING NASAL
MUCOUS SECRETION, METALLIC TASTE, DROWSINESS, VERTIGO, SLIGHT MUSCULAR WEAKNE
SS ACCOMPANIED BY INERTIA & DEPRESSION,NAUSEA, VOMITING, LOSS OF APPETITE
& GENERAL WEAKNESS. SKIN:PROLONGED CONTACT MAY CAUSE DRYING, CRACKING,
ITCHING, BURNING & SORES. EYES:SEVERE ITCHING, DAMAGE. CHRONIC:CANCER
HAZARD. CONTAINS MATERIALS WHICH ARE LISTED AS NERVE CARCINOGENS TO ANIMALS
(FP N).
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SP-605
CAGE:0DAC4
CAGE:0DAC4
CAGE:85884
============= Composition/Information on Ingredients =============
Ingred Name:HYDROFLUORIC ACID, HYDROGEN FLUORIDE
CAS:7664-39-3
RTECS #:MW7875000
Fraction by Wt: 5-9%
Other REC Limits:2.5 PPM
ACGIH TLV:C 2.6 MG/CUM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:SULFURIC ACID (CONFIRMED HUMAN CARCINOGEN BY IARC - GROUP
1) *97-3*
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 10-20%
OSHA PEL:1 MG/CUM
ACGIH TLV:1 MG/CUM=IC
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: SEVERE CHEMICAL
BURNS/BLINDNESS. INGESTION: HARMFUL/FATAL. CHEMICAL BURNS OF
MOUTH/THROAT & STOMACH. INHALATION: DAMAGES AIRWAYS/LUNGS,
DEPENDING UPON AMOUNT & DURATION OF EXPOSURE. CAUSE S LIGHT
IRRITATION TO BRONCHITIS/PNEUMONIA. PEOPLE W/ASTHMA/LUNG PROBLEMS
MAY BE MORE SUSCEPTIBLE.(SEE SUPP)
Explanation of Carcinogenicity:SEE INGEDIENTS.
Effects of Overexposure:CHEMICAL BURNS, PAIN, IRRITATION, MOTTLING OF
TEETH, SORENSS, STIFFNESS OF SOME JOINTS
Medical Cond Aggravated by Exposure:ASTHMA, LUNG PROBLEMS.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/PLENTY OF COOL RUNNING WATER. REMOVE
CONTACT LENSES. CONTINUE FLUSHING FOR 15 MINS. INGESTION: RINSE
MOUTH AT ONCE; THEN DRINK ONE/TWO LARGE GLASSES OF WATER/MILK.
DON'T INDUCE VOMI TING. NEVER GIVE ANYTHING BY MOUTH IF
UNCONSCIOUS. INHALATION: IMMEDIATELY REMOVE TO FRESH AIR. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:PRODUCT DOESN'T SUPPORT COMBUSTION.
Unusual Fire/Explosion Hazard:DON'T MIX W/CHLORINATED
DETERGENTS/SANITIZERS, WILL CAUSE HAZARDOUS VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE/DAM LARGE RELEASES. PUMP TO
CONTAINERS/SOAK UP ON INERT ABSORBENT. FLUSH RESIDUE TO SEWER
W/PLENTY OF WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN.
Other Precautions:AVOID MISTING CONDITIONS/DUSTS.
============= Exposure Controls/Personal Protection =============
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
HEALTH HAZ CONT'D: REPEATED EXPOSURE TO FLUORIDE CAN CAUSE MOTTLING OF
TEETH & FLUOROSIS, WHICH IS CHARACTERIZED BY SORNESS & STIFFNESS OF
SOME JOINTS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F
Spec Gravity:1.16
pH:1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS TO GREEN LIQUID; BLAND ACID ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACID
Stability Condition to Avoid:MIX ONLY W/WATER. CAN REACT VIOLENTLY
W/ALKALINE MATERIAL.
Hazardous Decomposition Products:WILL CAUSE HAZARDOUS VAPORS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS. D002 CORROSIVE. NA1790.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BUTANOIC ACID ETHYL ESTER, O-413
CAGE:84898
CAGE:84898
CAGE:8Y898
============= Composition/Information on Ingredients =============
Ingred Name:BUTYRIC ACID, ETHYL ESTER; (BUTANOIC ACID ETHYL ESTER)
CAS:105-54-4
RTECS #:ET1660000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(RAT) 13000 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT LENSES SHOULD NOT BE WORN IN
THE LABORATORY. ALL CHEMICALS SHOULD BE CONSIDERED HAZARDOUS-AVOID
DIRECT PHYSICAL CONTACT! ACUTE:CAN BE HARMFUL IF INHALED. CAN BE
HARMFUL IF SWALLOWED. CAN BE HA RMFUL IF ABSORBED THROUGH THE SKIN.
CANCAUSE EYE IRRITATION. DUST AND/OR VAPORS CAN CAUSE
IRRITATION(EFTS OF OVEREEXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:TO RESPIRATORY TRACT. CAN BE
IRRITATING TO MUCOUS MEMBRANES. CAN CAUSE SKIN IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:ANTIDOTE IS SUBSTANCE INTENDED TO COUNTERACT EFT OF A POIS.
IT SHOULD ADMIN ONLY BY PHYS/TRAINED EMER PERS. MED ADVICE CAN BE
OBTAINED FROM A POIS CTL CTR. INGEST:CALL MD IMMEDIATELY .
EYES:FLUS H CONTINUOUSLY W/WATER FOR @ LEAST 15 MINS. SKIN:FLUSH
W/WATER FOR 15-20 MINS. IF NO BURNS HAVE OCCURRED-USE SOAP & WATER
TO CLEANSE SKIN. INHAL:REMOVE PATIENT TO FRESH AIR. ADMIN OXYG IF
(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:66.2F,19.0C
Extinguishing Media:FLAMMABLE. CARBON DIOXIDE, DRY CHEMICAL POWDER OR
WATER SPRAY.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:THIS IS A FLAMMABLE CHEMICAL.
================== Accidental Release Measures ==================
Spill Release Procedures:EVAC AREA. WEAR APPROP OSHA-REGULATED EQUIP.
VENTILATE AREA. SWEEP UP & PLACE IN AN APPROP CNTNR. HOLD FOR
DISPOSAL. WASH CONTAMD SURFACES TO REMOVE ANY RESIDUES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE APPROP NIOSH/MSHA APPRVD SFTY
EQUIP. AVOID CONT W/SKIN, EYES & CLTHG. KEEP TIGHTLY CLSD & STORE
IN COOL DRY PLACE. STORE ONLY W/COMPAT CHEMICALS.
Other Precautions:PERSONS NOT SPECIFICALLY & PROPERLY TRAINED SHOULD
NOT HNDL THIS CHEM/ITS CNTNR. THIS PROD IS FURNISHED FOR LAB USE
ONLY! OUR PRODS MAY NOT BE USED AS DRUGS, COSMETICS,
AGRICULTURAL/PESTICIDAL PRODS, FOOD ADDITIVES/AS HOUSEHOLD
CHEMICALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:HOOD.
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC:PATIENT IS HAVING DFCLTY BRTHG. IF PATIENT HAS STOPPED
BRTHG ADMIN ARTF RESP. IF PATIENT IS IN CARD ARREST ADMIN CPR.
CONTINUE LIFE SUPPORTING MEASURES UNTIL MED ASSISTANCE HAS ARRIVED.
GET MED ATTN IF NEC. DO NOT WEAR SHOES/CLTHG UNTIL ABSOLUTELY FREE
OF ALL CHEMICAL ODORS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:248F,120C
Melt/Freeze Pt:M.P/F.P Text:-135F,-93C
Vapor Density:0.878
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:VERY SLIGHTLY SOL
Appearance and Odor:COLORLESS LIQUID; FRUITY, PERFUME LIKE, OR PLEASANT
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG BASES, STRONG ACIDS.
Stability Condition to Avoid:FLAMMABLE. SENSITIVE TO HEAT.
Hazardous Decomposition Products:DECOMPOSITION LIBERATES TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. DISPOSAL MUST BE I/A/W FEDERAL, STATE &
LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MITSUI TURBINE OIL AD 68
CAGE:S5456
CAGE:S5456
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, SOLVENT-REFINE LIGHT
NAPHTHENIC
CAS:64741-97-5
RTECS #:PY8041000
OSHA PEL:5 MG/CUM (MIST)
ACGIH TLV:5 MG/CUM (MIST)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER. SKIN: WASH W/SOAP & WATER. INGESTION:
GIVE VEGETABLE OIL. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:482F
Extinguishing Media:FOAM OR CO2
Fire Fighting Procedures:COOL FIRE SURFACE. USE WATER MIST TO PROTECT
BODY. WEAR SCBA & FULL PROTECTIVE CLOTHING.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILL: WIPE OFF W/PAPER OR CLOTH. LARGE
SPILL: VACUUM TO COLLECTION CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN AN AIRTIGHT CONTAINER & AWAY
FROM HEAT & FIRE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS REQUIRED
Ventilation:AS REQUIRED
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:384F
Vapor Pres:0.01
Spec Gravity:0.882
Solubility in Water:INSOLUBLE
Appearance and Odor:LIQUID W/MINERAL OIL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:HEAT, FIRE, & HIGH TEMPERATURES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CS 5387 BLACK
CAGE:79833
CAGE:79833
CAGE:6X798
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA 313) (CERCLA)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 69.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM
ACGIH TLV:200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VOC = 5.37 LB/GL, 0.677 KG/LTR
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
Ingred Name:TETRAHYDROFURAN (CERCLA)
CAS:109-99-9
RTECS #:LU5950000
Fraction by Wt: 7.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM
ACGIH TLV:200 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TRADESECRET #139725002-5044P
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE NAUSEA &/OR NARCOSIS. SEVERE EYE
BURNS. CHRONIC: MAY CAUSE LIVER/KIDNEY DAMAGE. CAN CAUSE NERVOUS
SYSTEM WEAKNESS IN HANDS/FEET.
Effects of Overexposure:IRRITATION TO EYES & MUCOUS MEMBRANES. CAN ALSO
CAUSE SKIN DRYNESS. LIQUID INGESTION MAY RESULT IN VOMITING,
WEAKNESS IN HANDS & FEET. THF CAN CAUSE LIVER/KIDNEY ABNORMALITIES.
CAN SEVERELY BURN EYES.
Medical Cond Aggravated by Exposure:RESPIRATORY AILMENTS.
======================= First Aid Measures =======================
First Aid:IN EMERGENCY SITUATIONS NOTIFY DR IMMEDIATELY. SKIN: WASH
W/SOAP & WATER. GET MEDICAL AID. EYES: FLUSH ABUNDANTLY W/CLEAN
WATER & CALL DR. INGESTION: DON'T INDUCE VOMITING. REFER TO DR. IN
CASE OF EXC ESSIVE INHALATION REMOVE TO FRESH AIR OR GIVE OXYGEN.
USE CPR IF PATIENT NOT BREATHING. REFER TO DR.
===================== Fire Fighting Measures =====================
Flash Point Method:OC
Flash Point:6F,-14C
Autoignition Temp:Autoignition Temp Text:610F
Lower Limits:1.8
Upper Limits:11.8
Extinguishing Media:CO2, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:NIOSH/MSHA APPROVED SCBA SHOULD BE WORN. USE
WATER SPRAY TO COOL FIRE EXPOSED STRUCTURES & DISPERSE VAPOR CLOUD
IF FIRE NOT PRESENT.
Unusual Fire/Explosion Hazard:VAPOR HEAVIER THAN AIR, MAY TRAVEL
CONSIDERABLE DISTANCES TO SOURCE OF IGNITION & FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SPILL IN
SAND/EARTH/VERMICULITE/OIL-DRI/SOL-SPEED-DRI. SHOVEL ABSORBED
MATERIAL INTO STEEL CONTAINER & COVER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN APPROVED SOLVENT STORAGE
AREA. KEEP TIGHTLY CLOSED. KEEP AWAY FROM HEAT, OPEN FLAMES,
SPARKS, HOT SURFACES, OXIDIZING AGENTS.
Other Precautions:NA
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED ATMOSPHERE SUPPLYING OR
AIR-PURIFYING RESPIRATOR FOR ORGANIC VAPORS AS REQUIRED TO MAINTAIN
EXPOSURE LEVELS BELOW RECOMMENDED LIMITS.
Ventilation:LOCAL EXHAUST TO REMOVE VAPORS IN PROCESSING. MECHANICAL
EXHAUST/EXPLOSION PROOF EQUIP TO KEEP VAPOR CONCENTRATION ** <S
Other Protective Equipment:PROTECTIVE CLOTHING AS REQUIRED TO PREVENT
SKIN CONTACT.
Work Hygienic Practices:KEEP AREA CLEAN. CLEAN UP SPILLS IMMEDIATELY.
PRACTICE GOOD PERSONAL HYGIENE.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:151F,66C
Vapor Pres:76.0 @ 20C
Vapor Density:2.5
Spec Gravity:0.901
Appearance and Odor:BLACK LIQUID, CHARACTERISTIC SOLVENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NA
Stability Condition to Avoid:HEAT, OPEN FLAMES, SPARKS, HOT SURFACES,
OXIDIZING AGENTS.
Hazardous Decomposition Products:OXIDES OF CARBON, SULFUR, NITROGEN,
HYDROGEN CHLORIDE, HYDROGEN SULFIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE,
LOCAL, CHEMICAL, SOLVENT WASTE DISPOSAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BLEND ISOPROPYL-METHANOL, P3899
CAGE:DO735
CAGE:DO735
CAGE:87664
============= Composition/Information on Ingredients =============
Ingred Name:FIRST AID PROC: GLASSES OF WATER & STICKING FINGER DOWN
THROAT. GET IMMED MED ATTN. DO NOT GIVE ANYTHING BY (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: MOUTH TO AN UNCONSCIOUS OR CONVULSING PERSON. AFTER
THE PATIENT HAS VOMITED, GIVE MILK, WATER OR SOLUTION (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: OF SODIUM BICARBONATE IN WATER (1 TSP/1 QT).
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: VAPS MAY BE SATISFACTORY. IN ANY EVENT, ALWAYS
WEAR EYE PROT. EXTING ALL IGNIT SOURCES & ENSURE ALL (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: HNDLG EQUIP IS ELEC GROUNDED. FOR SML SPILLS/DRIPS,
MOP/WIPE UP & DISP OF IN DOT-APPRVD WASTE CONTRS. (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: FOR LGE SPILLS, CONTAIN BY DIKING W/SOIL/OTHER
NON-COMBUST ABSORB MATLS & THEN PUMP INTO DOT-APPRVD (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: WASTE CONTRS; OR ABSORB W/NON-COMBUST SORBENT MATL,
PLACE RESIDUE IN DOT-APPRVD WASTE CONTRS. KEEP OUT (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: OF SEWERS, STORM DRAINS, SURFACE WATERS AND SOIL.
COMPLY WITH ALL APPLICABLE GOVERNMENTAL REGULATIONS (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: ON SPILL REPORTING, AND HANDLING AND DISPOSAL OF
WASTE.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH: TO PROPER WASTE DISPOSAL, AS ABOVE.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: DO NOT GET IN EYES, ON SKIN/ON CLTHG. REPAIR &
MAINTENANCE PREC: DO NOT CUT, GRIND, WELD/DRILL ON/ (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: NEAR THIS CONTR. COMPONENTS OF THIS MIX ARE
VOLATILE & WILL EVAP IF CONTR IS LEFT OPEN/IF IT IS STORED (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17: IN WARM PLACES. THIS WILL CHANGE COMPOSITION OF
THIS MIX & RESULTING SOLN MAY NO LONGER BE SUITABLE FOR (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 4: EXERTED ON CNS, ESP OPTIC NERVE. CHRONIC: PRLNG/RPTD
EXPOS MAY RSLT IN CNS DMG, BLINDNESS, DMG TO PANCREAS/DEATH.
RTECS #:9999999ZZ
Ingred Name:METHANOL (SARA 313) (CERCLA) LD50 (ORAL RAT): 5.628 G/KG
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 75%
OSHA PEL:200 PPM, S
ACGIH TLV:200PPM/250STEL, S
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPYL ALCOHOL (SARA 313) LD50 (ORAL RAT): 5.84 G/KG
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 25%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM/500STEL
Ingred Name:SUP DAT: METHANOL IS RAPID BUT EXCRETION IS SLOW, RESULTING
IN DELAYED EFTS/COMPOUNDING EFTS OF RPTD EXPOS. (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3: INITIAL SYMPS MAY ONLY BE MILD INTOXICATION BUT
THESE MAY BECOME MORE SEV 12-18 HRS LATER. TOX EFTS ARE (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 18: ITS INTENDED USE/IT MAY HAVE DIFFERENT HAZ
PROPERTIES THAN THOSE DESCRIBED HERE. OBSERVE STOR ADVICE TO (ING
20)
RTECS #:9999999ZZ
Ingred Name:ING 19: MINIMIZE EVAP. CONTRS, EVEN THOSE THAT HAVE BEEN
EMPTIED, WILL RETAIN PRODUCT RESIDUE AND VAPORS. (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20: ALWAYS OBEY HAZARD WARNINGS AND HANDLE EMPTY
CONTAINERS AS IF THEY WERE FULL.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: VAPS & MISTS IRRITATE
NOSE & THROAT. INHAL OF HIGHER CONCS MAY CAUSE HDCH, NAUS, VOMIT &
COMA. INHAL OF VERY HIGH CONCS/PRLNG EXPOS MAY CAUSE UNCON/DEATH.
PRLNG/RPTD EXPOS/BRTHG VERY HIG H CONCS MAY CAUSE HDCH, NAUS,
VOMIT, DIZZ, VISUAL DISTURB, GIDDINESS, INTOXICATION, SLEEPINESS,
UNCON (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: & DEATH. INITIAL SYMPS OF INHAL MAY
ONLY BE MILD INTOXICATION BUT MAY BECOME MORE SEV AFTER 12-18 HRS.
TOX EFTS ARE EXERTED ON CNS, ESP OPTIC NERVE. EYE: VAPS WILL
IRRITATE EYES. LIQ & MISTSWILL IRRITATE & MAY BURN EYES. SKIN:
BRIEF CONT MAY DRY SKIN. PRLNG/RPTD CONT MAY IRRITATE SKIN, CAUSING
DERM.(SUP DAT)
Medical Cond Aggravated by Exposure:PREEXISTING EYE, SKIN AND
RESPIRATORY DISORDERS MAY BE AGGRAVATED.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. GIVE ARTF RESP IF NOT BRTHG. GET
IMMED MED ATTN. EYES: IMMED FLUSH W/LOTS OF RUNNING WATER FOR AT
LEAST 15 MIN, LIFTING UPPER & LOWER EYELIDS OCCAS. GET IMMED MED
ATTN. SKI N: IMMED WASH W/LOTS OF SOAP & WATER. REMOVE CONTAM CLTHG
& SHOES; WASH BEFORE REUSE. GET MED ATTN IF IRRIT PERSISTS AFTER
WASHING. INGEST: IF CONSCIOUS, IMMED INDUCE VOMIT BY GIVING 2 (ING
6)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:<60F,<16C
Extinguishing Media:USE DRY CHEMICAL, CARBON DIOXIDE, OR ALCOHOL FOAM.
DO NOT USE WATER TO FIGHT FIRE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO COOL NEARBY CONTAINERS AND
STRUCTURES EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:EXTING ALL NEARBY SOURCES OF IGNIT. WATER
WILL EXTRACT FLAMM CO-SOLV WHICH WILL FORM FLAMM SUPERNATANT LAYER.
VAPS ARE HVR/AIR & MAY TRAVEL TO IGNIT (SUP DAT)
================== Accidental Release Measures ==================
RUB APRON & NIOSH/MSHA APPRVD SCBA IN PRESS DEMAND MODE/NIOSH/MSHA
APPRVD SUPPLIED-AIR RESP. IF SPILL/LEAK IS SML, A NIOSH/MSHA APPRVD
FULL FACEPIECE AIR-PU RIFYING CARTRIDGE RESP EQUIPPED FOR ORG(ING
9)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS AND
FLAMES. STORE IN COOL, DRY, WELL-VENTILATED PLACE AWAY FROM
INCOMPATIBLE MATERIALS.
Other Precautions:VENT CONTR FREQUENTLY, & MORE OFTEN IN WARM WEATHER,
TO RELIEVE PRESS. ELEC GROUND ALL EQUIP WHEN HNDLG THIS PROD & USE
ONLY NON-SPARKING TOOLS. KEEP CONTR TIGHTLY CLSD WHEN NOT IN USE.
DO NOT USE PRE SS TO EMPTY CONTR. (ING 16)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH APPRVD RESP APPROP FOR VAP/MIST CONC
AT POINT OF USE. APPROP RESPS MAY BE A FULL FACEPIECE OR HALF MASK
AIR-PURIFYING CARTRIDGE RESP EQUIPPED FOR ORG VAPS/MISTS, SCBA IN
PRESS DEMAND MODE/S UPPLIED-AIR RESPIRATOR.
Ventilation:LOCAL MECHANICAL EXHAUST VENTILATION CAPABLE OF MAINTAINING
EMISSIONS AT THE POINT OF USE BELOW THE LOWEST PEL.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH & DELUGE
SHOWER . LONG-SLEEVED SHIRT, TROUSERS, SAFETY SHOES, RUBBER APRON.
Work Hygienic Practices:WASH THORO AFTER HNDLG. CONT LENSES SHOULD NOT
BE WORN WHEN WORKING W/CHEMS; THEY MAY CONTRIBUTE TO SEV OF EYE
INJURY.
Supplemental Safety and Health
EXPLO HAZ: SOURCE & FLASH BACK. EFTS OF OVEREXP: METHANOL MAY BE
ABSORBED THRU INTACT SKIN TO PRDCE SYSTEMIC EFTS. INGEST:
SWALLOWING LGE QTYS CAUSES HDCH, NAUS, VOMIT & PERHAPS UNCON.
SWALLOWING 100- 250 ML OF METHANOL CAN BE FATAL. SWALLOWING LESSER
QTYS CAN CAUSE BLINDNESS, DIZZ, HDCH/NAUS. ABSORPTION OF (ING 3)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:155F,68C
Vapor Pres:96
Vapor Density:1.25
Spec Gravity:0.79 (H*2O=1)
Evaporation Rate & Reference:>2 (BUTYL ACETATE=1)
Solubility in Water:100%
Appearance and Odor:CLEAR, COLORLESS LIQUID, WITH ALCOHOLIC ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS.
Stability Condition to Avoid:HEAT, SPARKS, AND OPEN FLAMES.
Hazardous Decomposition Products:MAY LIBERATE CARBON MONOXIDE OR CARBON
DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISP OF CONTAM PROD & MATLS USED IN CLEANING UP
SPILLS/LEAKS IN MANNER APPRVD FOR THIS MATL. CONSULT APPROP FED,
STATE & LOC REGULATORY AGENCIES TO ASCERTAIN PROPER DISP PROC.
NOTE: EMPTY CONTRS CAN H AVE RESIDUES, GASES & MISTS & ARE SUBJECT
(ING 15)
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DISHWASHING COMP. HAND-CID A-A-5
CAGE:6D885
CAGE:81348
CAGE:6D885
============= Composition/Information on Ingredients =============
Ingred Name:ALKYD ARYLSULFONATE
RTECS #:AZ8400000
Fraction by Wt: 17%.
Ingred Name:SODIUM TRIPOLYPHOSPHATE
RTECS #:NE7700000
Fraction by Wt: 23%.
Ingred Name:SODIUM SULFATE (ANHYDROUS)
RTECS #:WE1700000
===================== Hazards Identification =====================
Effects of Overexposure:MILDLY IRRITATING TO SKIN & MUCOUS
MEMBRANES.FATIGUING AGENT TO THE SKIN OF HUMANS.
======================= First Aid Measures =======================
First Aid:FLUSH THOROUGHLY W/WATER IF EYE OR EXCESSIVE DSKIN CONTACT
OCCURS. IF IRRITATION PERSISTS,DEEK MEDICAL ATTENTION; HAVE
PHYSICIAN TRAT SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER,FOAM, CARBON DIOXIDE
Fire Fighting Procedures:DO NOT ENTER ANY CONFINED FIRE SPACE W/O PROPR
EQPMT,BREATHI
Unusual Fire/Explosion Hazard:COMBUSTIBLE WHEN IN DIRECT CONTACT
W/FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP & SHOVEL INTO CONTAINER.DUSK MASK
SUGGESTED IF PICKUP OCCURS IN CONFINED AREA.BECAUSE THE MATERIAL IS
COMPLETLY SOLUBLE, SPILLAGE CAN BE WASHED AWAY WITH PLENTY OF
WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL DRY AREA. IF CONTAINER
BAG IS BROKEN, SEAL.MATERIAL DROWS MOISTURE EXTREMELY EASY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DUST MASKS SUGG IN POORLY VENTILAT AREAS OR
F/PROLNG EXTENSIVE CONTC
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:0.5@25
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT,YELLOWISH-WHITE POWDER W/A BLAND ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
==================== Disposal Considerations ====================
Waste Disposal Methods:WHEN MIXED W/WATER AT A RATE OF 1 CUP/10 GALLONS
YOU HAVE A LOW-PHOSPHATE DETERGENT. DISPOSE OF IN ACCORDANCE
W/ENVIRONMENTAL LAWS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ETHYL ALCOHOL TECHNICAL, 190 PROOF
CAGE:61305
CAGE:61305
============= Composition/Information on Ingredients =============
Ingred Name:FIRST AID PROC: EYES SHOULD BE FLUSHED FOR AT LEAST 15 MIN.
REMOVE & WASH CONTAMD CLTHG BEFORE REUSE. GET MD IMMED.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:TO SECURE CNTNRS.WHERE NECESSARY,COLLECT USNG
ABSORB MEDIA.IN EVENT OF AN UNCONTROLLD RLEASE OF THIS (ING 5)
RTECS #:9999999ZZ
Ingred Name:MATL,USER SHOULD DETERMINE IF RLEASE IS REPORTABLE UNDER
APPLIC LAWS & REGS. OTHER PREC: SHOULD BE FOLLOWED FOR (ING 6)
RTECS #:9999999ZZ
Ingred Name:ALL STORAGE & HANDLING.FREQUENT CAREFUL LEAKAGE INSPECTIONS
SHOULD BE DONE.AUTOMATIC SPRINKLER SYS SHOULD BE (ING 7)
RTECS #:9999999ZZ
Ingred Name:PROVIDED.ISOLATE FROM OXIDS,CHEM CAPABLE OF SPONTANEOUS
HEATING, MATERIALS REACTING WITH AIR OR MOISTURE TO (ING 8)
RTECS #:9999999ZZ
Ingred Name:LIBERATE HEAT,IGNITION SOURCES & EXPLOS.CONSULT LOCAL FIRE
CODES FOR ADDITIONAL STORAGE INFO. WHEN CONTENTS ARE (ING 9)
RTECS #:9999999ZZ
Ingred Name:BEING TRANSFERRED,THE METALLIC CONTAINER MUST BE BONDED TO
THE RECEIVING CONTAINER & GROUNDED TO AVOID STATIC (ING 10)
RTECS #:9999999ZZ
Ingred Name:DISCHARGES.NEVER USE PRESSURE TO EMPTY.REPLACE CLOSURE
SECURELY AFTER EACH OPENING.KEEP MATL PACKAGD IN DRUMS OR(ING 11)
RTECS #:9999999ZZ
Ingred Name:BOTTLES OUT OF SUN & AWAY FROM HEAT.RMOVE CLOSURE
CAREFULLY;INTERNAL PRESS MAY BE PRESNT.KEEP CLOSURE UP TO PVNT(ING
12)
RTECS #:9999999ZZ
Ingred Name:LEAKAGE.CONTNER HAZ WHEN EMPTY.SINCE EMPTIED CONTNERS
RETAIN RESIDUAL PROD (VAP & LIQ), ALL PRECAUTIONS MUST BE (ING 13)
RTECS #:9999999ZZ
Ingred Name:OBSERVED. CAUTION: FOR MANUFACTURING, PROCESSING, REPACKING
OR INDUSTRIAL USE. NOT FOR HOUSEHOLD USE.
RTECS #:9999999ZZ
Ingred Name:ETHYL ALCOHOL (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 93.8%
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9192
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 6.2%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: EXPOSURE TO OVER 1000 PPM MAY
CAUSE HDCH, DROWSINESS AND LASSITUDE, LOSS OF APPETITE & INABILITY
TO CONCENTRATE. IRRITATION OF THROAT. INGEST: CAN CAUSE DEPRESSION
OF CNS, NAUS, VOMIT, DIARRHEA . EYE: LIQUID OR VAP MAY CAUSE
IRRITATION. SKIN: MAY CAUSE IRRITATION AND DEFATTING OF SKIN ON
PRLNGD CONTACT.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST: IF VICTIM IS CONSCIOUS & ABLE TO SWALLOW, HAVE VICTIM
DRINK WATER/MILK TO DILUTE. NEVER GIVE ANYTHING BY MOUTH IF VICTIM
IS UNCON/HAVING CONVULSIONS. GET MD/POIS CONTROL CTR IMMED. INHAL:
IMME D MOVE VICTIM TO FRESH AIR. IF VICTIM HAS STOPPED BRTHG, GIVE
ARTF RESP, PREF MOUTH-TO-MOUTH. GET MD IMMED. EYES & SKIN: IMMED
FLUSH AFFECTED AREA W/PLENTY OF COOL WATER. (SEE INGRED 3)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:57.0F,13.9C
Lower Limits:3.3
Upper Limits:19
Extinguishing Media:DRY CHEMICAL, ALCOHOL FOAM, OR CARBON DIOXIDE,
WATER MAY BE INEFFECTIVE.
Fire Fighting Procedures:WATER SHOULD BE USED TO KEEP FIRE-EXPOSED
CNTNRS COOL. IF LEAK/SPILL HAS NOT IGNITED, USE WATER SPRAY TO
DISPERSE VAPS & TO PROTECT MEN (SEE SUPP DATA)
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID UNCONTROLLED RELEASES OF THIS MATL.
WHERE SPILLS ARE POSSIBLE, A COMPREHENSIVE SPILL RESPONSE PLAN
SHOULD BE DEVELOPED AND IMPLEMENTED. WEAR APPROP NIOSH/MSHA APPRVD
RESP PROT & PROTECTIVE CLTHG . CONTAIN SPILLED MATL. TRANSFER (SEE
INGRED 4)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT CNTNR AGAINST PHYSICAL DMG.
DETACHED/OUTSIDE STORAGE IS PREF. INSIDE STORAGE SHOULD BE IN AN
NFPA APPRVD FLAM LIQ STORAGE (SEE OTHER PREC)
Other Precautions:HNDLG/STOR PREC: ROOM OR CABINET. ALL IGNIT SOURCES
SHOULD BE ELIMINATED. SMOKING SHOULD BE PROHIBITED IN STORAGE
AREAS. ELEC INSTALLATIONS SHOULD BE I/A/W ARTICLE 501 OF NATIONAL
ELEC CODE. NFPA 30, FLAM & COMBUST LIQ CODE, (SEE INGRED 5)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE EXPOSURE IS LIKELY TO EXCEED ACCEPTABLE
CRITERIA, USE NIOSH/MSHA APPRVD RESPIRATORY PROTECTION EQUIPMENT.
RESPIRATORS SHOULD BE SELECTED BASED ON THE FORM AND CONCENTRATION
OF CONTAMINANT IN AIR .
Ventilation:HANDLE IN THE PRESENCE OF ADEQUATE VENTILATION.
Other Protective Equipment:IMPERVIOUS PROTECTIVE CLOTHING.
Work Hygienic Practices:WASH HANDS FREQUENTLY AND THOROUGHLY DURING
CONTACT WITH MATERIAL AND AT END OF WORKDAY .
Supplemental Safety and Health
FIRE FIGHT PROC: ATTEMPTING TO STOP A LEAK. WATER SPRAY MAY BE USED TO
FLUSH SPILLS AWAY FROM EXPOSURES AND TO DILUTE SPILLS TO NONFLAM
MIXT. FIREFIGHTERS SHOULD WEAR NIOSH/MSHA APPRVD SCBA IN POSITIV E
PRESS MODE W/FULL FACEPIECE WHEN THERE IS A POSSIBILITY OF EXPOSURE
TO SMOKE, FUMES OR HAZ DECOMP PROD.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:173F,78C
Melt/Freeze Pt:M.P/F.P Text:-173F,-114C
Vapor Pres:44.6@68F
Vapor Density:1.59
Spec Gravity:0.794 @ 60F
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR AND COLORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONTACT WITH ACETYL CHLORIDE AND A WIDE RANGE OF OXIDIZING AGENTS MAY
REACT VIOLENTLY.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:ALL RECOVERED MATL SHOULD BE PACKAGED, LABELED,
TRANSPORTED, AND DISPOSED OR RECLAIMED IN CONFORMANCE WITH
APPLICABLE LAWS AND REGULATIONS AND IN CONFORMANCE WITH GOOD
ENGINEERING PRACTICES.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:RELIEF WIPES/WITCH HAZEL & LANOLIN
CAGE:OO146
CAGE:OO146
CAGE:0AHM9
============= Composition/Information on Ingredients =============
Ingred Name:WITCH HAZEL
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MAY BECOME IRRITATED BY CONTACT.
SKIN: SENSITIVE SKIN MAY BE IRRITATED.
Effects of Overexposure:EYES: IRRITATION. SKIN: IRRITATION.
Medical Cond Aggravated by Exposure:SESITIVE SKIN MAY BE IRRITATED.
WITCH HAZEL IS A KNOWN ASTRINGENT.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. SKIN: WASH AREA WITH
SOAP AND WATER. INGESTION: GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:110F,43C
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICALS.
Fire Fighting Procedures:WEAR APPROPRIATE PROTECTIVE EQUIPMENT. FIGHT
FIRE FROM A SAFE DISTANCE.
Unusual Fire/Explosion Hazard:VAPOR FROM PRODUCT MAY BE IGNITABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:INDIVIDUAL SINGLE-USE PACKETS PRECLUDE
SPILLAGE PROBLEMS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY ENVIRONMENT. AVOID
EXCESSIVE HEAT.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:NORMAL AIR CHANGES.
Other Protective Equipment:NONE NORMALLY REQUIRED.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING.
Supplemental Safety and Health
INFORMATION GIVEN IS FOR WITCH HAZEL. ITEM IS A RAYON FIBER PAD
IMPREGNATED WITH WITCH HAZEL AND LANOLIN AND INDIVIDUALLY SEALED IN
LAMINATED PLASTIC FOIL.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>190F,>88C
Vapor Pres:>18.75
Vapor Density:1.0
Spec Gravity:0.985
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:SOLUBLE
Appearance and Odor:MEDICATED NONWOVEN RAYON FIBER INDIVIDUALLY SEALED
IN LAMINATED PLASTIC FOIL.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF USED WIPES IN ACCORDANCE WITH LOCAL,
STATE AND FEDERAL REGULATIONS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:TT-P-81E 14277
Preparer's Name:ROBERT COMMISSO
CAGE:58963
CAGE:58963
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL SPIRITS (VAPOR PRESSURE 2.0 MM HG @ 68F)
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 15%
Other REC Limits:NONE SPECIFIED
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:VOC 1.85 LB/GL 222 G/L
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. PROLONGED OR
REPEATED CONTACT: SKIN IRRITATION. INHAL OF HIGH CONC: LUNG
CHANGES, NAUSEA, VOMITING, COUGH, PULMONARY IRRITATION AND CENTRAL
NERVOUS SYSTEM DEPRESSION. INGESTION: GAST ROINTESTINAL
DISTURBANCES. ASPIRATION OF THIS PRODUCT INTO THE LUNGS MAY CAUSE
PNEUMONITIS, PULMONARY EDEMA & HEMORRAGE
Effects of Overexposure:INHAL: BREATHING OF HIGH VAPOR CONC:
DROWSINESS, DIZZINESS, FATIGUE, FOLLOWED BY COMA. EYE: IRRITATION.
SKIN: PROLONG/REPEAT CONTACT-IRRITATION, DERMATITIS, DEFATTING.
INGESTION: ASPIRATION OF THIS PR ODUCT INTO LUNGS MAY CAUSE
PNEUMONTITIS, PULMONARY EDEMA AND HEMORRAGE. INGEST MAY CAUSE
GASTROINTESTINAL DISTURBANCES.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING
DISEASES IN OR HISTORY OF AILMENTS INVOLVING SKIN, CENTRAL NERVOUS
SYSTEM, LIVER AND KIDNEY.
======================= First Aid Measures =======================
First Aid:EYE: IMMEDIATELY FLUSH WITH LARGE AMOUNTS OF WATER FOR 15
MINUTES. SEEK MEDICAL AID. SKIN: WASH THOROUGHLY WITH SOAP & WATER.
SEEK MEDICAL AID IF IRRITATION PERSISTS. INGESTION: IMMEDIATELY
SEEK MEDIC AL AID. DO NOT INDUCE VOMITING. DO NOT ATTEMPT TO GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:100F,38C
Autoignition Temp:Autoignition Temp Text:474F
Lower Limits:1.0
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:APPROVED GAS MASK REQUIRED FOR FIRE FIGHTING
PERSONNEL. WATER MAY BE INEFFECTIVE. WATER MAY BE USED TO COOL
CONTAINERS. IF WATER USED, FOG NOZZLES ARE PREFERRED
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS AND OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP LEAK IF NO RISK INVOLVED. REMOVE ALL
SOURCES OF IGNITION. STAY UPWIND. ABSORB WITH INERT MATERIAL. FLUSH
AREA WITH WATER. VENTILATE AREA FOR AT LEAST 24 HOURS OR UNTIL AREA
HAS BEEN DECLARED SAFE .
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNRS CLOSED & UPRIGHT TO
PREVENT LEAKAGE. AVOID FLAMES, WELDING, OPEN LIGHTS, ETC. AVOID
BREATHING OF VAPOR/SPRAY MIST. AVOID SKIN/EYE CONTACT
Other Precautions:MAINTAIN GOOD PERSONAL HYGIENE. DO NOT USE IN
CONFINED AREAS, TANK OR PIT, WITHOUT ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENT DOES NOT MAINTAIN INHAL EXPOSURES BELOW
TLV(PEL), USE MSHA/NIOSH APPROVED UNITS. USE UNITS PER CURRENT 29
CFR1910.134 AND FOLLOW MFRS' INSTRUCTIONS/WARNINGS. IF WITHIN OSHA
PROTECTION FACTOR,AIR PURIFYING OV/FILTER UNITS OK FOR USE
Ventilation:LOCAL AND MECHANICAL EXHAUST
Other Protective Equipment:EYE BATH AND SAFETY SHOWER.
Work Hygienic Practices:MAINTAIN GOOD PERSONAL HYGIENE. DO NOT USE IN
CONFINED AREAS WITHOUT ADEQUATE VENTILATION.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:310F,154C
Vapor Density:> THAN AIR
Spec Gravity:(H2O=1) 1.4
Viscosity:75-80 KU
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:ESSENTIALLY NIL
Appearance and Odor:VISCOUS LIQUID WITH TYPICAL PAINT ODOR.
Percent Volatiles by Volume:32.2
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:FLAMES, SPARKS, SMOKING AND HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:USE INERT ABSORBENT MATERIALS ON SPILLS. DISPOSE
OF IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MARKER BOARD CLEANER FORMULA 404, 920080
CAGE:COMPL
CAGE:COMPL
============= Composition/Information on Ingredients =============
Ingred Name:BENZYL ALCOHOL
CAS:100-51-6
RTECS #:DN3150000
Ingred Name:ETHANOL, 2-BUTOXY-; (BUTYL CELLOSOLVE). (EGBE)
CAS:111-76-2
RTECS #:KJ8575000
Other REC Limits:PEL: 50 PPM (MFR)
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: CAUSES SLIGHT TO MODERATE IRRIT,
BLURRED VISION W/POSSIBLE CORNEAL INJURY. SKIN: PROLONGED CONTACT
MAY CAUSE MODERATE IRRIT, DEFATTING, DERMATITIS. INHAL: INHAL OF
VAPORS CAN CAUSE NASAL AND RES PIRATORY IRRIT, DIZZ, WEAKNESS,
FATIGUE, NAUSEA, HEADACHE, POSSIBLE UNCON & EVEN ASPHYXIATION.
INGEST: (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: SLIGHTLY TOXIC, INGEST OF LGE AMTS
MAY CAUSE LOSS OF CON. STOMACH CRAMPS, PAIN, NAUS, VOMIT & DIARR
MAY ALSO OCCUR. ANIMAL STUDIES CLEARLY DEMONSTRATED DOSE-RELATED
ADVERSE EFTS ON CNS, HEMA TOPOIETIC TISSUES, BLOOD, KIDNEYS &
LIVER, ASSOC W/ADMIN OF ETHYLENE GLYCOL MONBUTYL ETHER (EGBE) (SUPP
DATA)
Medical Cond Aggravated by Exposure:NO DATA FOUND.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR, IF BRTHG DFCLT, ADMIN O*2, IF
BRTHG STOPPED GIVE ARTF RESP. KEEP PERS WARM & GET MED ATTN IMMED.
EYE: FLUSH EYES W/WATER FOR AT LEAST 15 MINS. GET MED ATTN. INGEST:
ADMIN L UKEWARM WATER(PINT)- DO NOT INDUCE VOMITING, CALL MD IMMED.
NOTE TO MD: NO SPECIFIC ANTIDOTE. TREATMENT OF OVEREXP SHLD BE
DIRECTED AT CONTROL OF SYMPS & CLINICAL CNDTN. SKIN:REMOVE
CONTAMD(SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:180F,82C
Extinguishing Media:WATER, CO*2, DRY CHEMICAL OR FOAM, CLASS A, BC, OR
ABC FIRE EXTINGUISHERS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:EXTING & DO NOT TURN ON IGNIT SOURCE UNTIL
AREA IS FREE FROM EXPLO/FIRE HAZ. KEEP PEOPLE AWAY. COLLECT FREE
PROD & ADD SAND/EARTH/OTHER SUIT ABSORB TO SPILL AREA. MIN BRTHG
VAPS/SKIN CONT & VENT CONFI NED SPACES. KEEP OUT OF SEWERS & (SUPP
DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CLOSURES TIGHT. AVOID EXPOSURE TO
EXCESSIVE HEAT.
Other Precautions:USE ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NOT NORMALLY NEEDED IF LOCAL EXHAUST
SATISFACTORY.
Ventilation:PROVIDE SUFFICIENT MECHANICAL VENTILATION TO MAINTAIN
EXPOSURE BELOW PEL.
Other Protective Equipment:TO PREVENT RPTD/PRLNG SKIN CONTACT, WEAR
IMPERVIOUS CLOTHING AND BOOTS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
FIRST AID PROC: CLTHG & FLUSH SKIN W/WATER. IF REDNESS, ITCHING/BURNING
SENSATION DEVELOPS, GET MED ATTN. SPILL PROC: WATERCOURSES BY
DIKING/IMPOUNDING. ADVISE AUTHS IF PROD HAS ENTERED SEWERS/WATERCO
URSES. EFTS OF OVEREXP: (EXTRACTED FROMDHHS(NIOSH) PUB # 90-118).
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:100F,38C
Spec Gravity:1.013
Evaporation Rate & Reference:</=1 (N-BUAC=1)
Solubility in Water:SOLUBLE
Appearance and Odor:CLOUDY AQUEOUS SOLUTION, SLIGHTLY SWEET ODOR.
Percent Volatiles by Volume:5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CO, CO*2, SILICONE DIOXIDE, ALDEHYDES
AND OTHER DECOMPOSITION PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL LOCAL, STATE AND
FEDERAL REGULATIONS. CONTAMINATED ABSORBENT MAY BE DEPOSITED IN A
LANDFILL IN ACCORDANCE WITH LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CALCO HEATING FUEL NO. 2
CAGE:81230
CAGE:81230
CAGE:0GYU1
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM MID-DISTILLATE (DIESEL MARINE FUEL)
CAS:68476-34-6
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 AS OIL MIST
ACGIH TLV:5 MG/M3 AS OIL MIST
Ingred Name:DISTILLATES, HYDRODESULFURIZED MIDDLE
CAS:64742-80-9
Other REC Limits:NONE RECOMMENDED
Ingred Name:DISTILLATES, STRAIGHT RUN MIDDLE
CAS:64741-44-2
RTECS #:LX3296000
Other REC Limits:NONE RECOMMENDED
Ingred Name:KEROSENE
CAS:8008-20-6
RTECS #:OA5500000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM 9091
Ingred Name:HYDRODESULFURIZED KEROSENE
CAS:64742-81-0
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:NAPHTHALENE (SARA III)
CAS:91-20-3
RTECS #:QJ0525000
Fraction by Wt: <3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 PPM/15 STEL
ACGIH TLV:10 PPM/15 STEL; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:LIGHT HYDROCARBON BLEND
CAS:64741-59-9
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS > 5ML/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE EYE IRRITATION. MIST OR
VAPOR MAY CAUSE RESPIRATORY TRACT IRRITATION. CNS DEPRESSANT.
INGESTION MAY CAUSE IRRITATION, CNS DEPRESSION, COMA AND DEATH.
SKIN CONTACT MAY CAUSE DRYING, CRACKING, DEFATTING DERMATITIS, &
IRRITATION WITH SEVERE ERYTHEMA & EDEMA. ABSORPTION OF LARGE
AMOUNTS MAY RESULT IN NARCOSIS.
Explanation of Carcinogenicity:THIS PRODUCT MAY CONTAIN SOME MIDDLE
DISTILLATES FOUND TO CAUSE POSITIVE RESPONSES IN SOME MUTAGENICITY
TESTS ON MICE.
Effects of Overexposure:GIDDINESS, NERVOUSNESS, HEADACHE, DIZZINESS,
WEAKNESS, WEIGHT LOSS, ANEMIA, NUMBNESS, PARALYSIS, NAUSEA,
VOMITING, INCOORDINATION, NARCOSIS, STUPOR, COMA, UNCONSCIOUSNESS,
DEATH. PROLONGED OR REPEATED EXPOSURE TO HIGH CONCENTRATIONS MAY
CAUSE DEGENERATIVE CHANGES TO LIVER AND KIDNEYS WITH POSSIBLE RENAL
FAILURE.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING
DISEASE IN OR A HISTORY OF AILMENTS INVOLVING THE LIVER, KIDNEY,
SKIN, CNS, OR REPRODUCTIVE SYSTEM ARE AT A GREATER THAN NORMAL RISK
WHEN EXPOSED TO THIS MATERIAL.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH IMMEDIATELY WITH PLENTY OF WATER FOR 15 MINUTES
WHILE LIFTING EYELIDS. GET MEDICAL ATTENTION. SKIN: REMOVE
CONTAMINATED CLOTHING. WASH SKIN WITH SOAP AND WATER. GET MEDICAL
ATTENTION. INHAL ATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRATION. GET MEDICAL ATTENTION. INGESTION: DO NOT
INDUCE VOMITING. IF VOMITING OCCURS, KEEP HEAD BELOW HIPS. GET
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:125F,52C
Extinguishing Media:DRY CHEMICAL, FOAM, CARBON DIOXIDE, WATER FOG
Fire Fighting Procedures:USE PROPER PROTECTIVE EQUIPMENT AND
SUPPLIED-AIR BREATHING EQUIPMENT FOR ENCLOSED AREAS. COOL FIRE
EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:INCOMPLETE COMBUSTION CAN PRODUCE CARBON
MONOXIDE. FUEL VAPORS ARE HEAVIER THAN AIR AND MAY TRAVEL TO REMOTE
SOURCES OF IGNITION WHERE THEY CAN EXPLODE & BURN.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. VENTILATE
AREA. STOP SPILL AT SOURCE. SMALL SPILL - REMOVE LIQUID BY
OIL-ABSORBING MATERIALS. LARGE SPILL - EXCLUDE PERSONS NOT WEARING
PROTECTIVE EQUIPMENT, DIKE AR EA OF SPILL AND PUMP LIQUID INTO
SALVAGE TANK.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE NEAR SOURCES OF IGNITION.
USE ONLY IN WELL VENTILATED AREA. KEEP CONTAINER CLOSED. NOT FOR
USE AS PORTABLE HEATER FUEL, EMITS TOXIC FUMES
Other Precautions:DO NOT PRESSURIZE, CUT, HEAT, WELD, OR EXPOSE "EMPTY"
CONTAINERS TO SOURCES OF IGNITION. VAPORS ARE HEAVIER THAN AIR AND
MAY TRAVEL A CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND
FLASH BACK.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR WITH ORGANIC
VAPOR CARTRIDGE IS RECOMMENDED. USE POSITIVE PRESSURE AIR-SUPPLIED
OR SCBA IN THE EVENT OF A LARGE SPILL.
Ventilation:USE THIS MATERIAL ONLY IN WELL VENTILATED AREAS. MECHANICAL
VENTILATION IS RECOMMENDED FOR USE IN ENCLOSED WORK AREAS.
Other Protective Equipment:APPROPRIATE IMPERVIOUS CLOTHING AND
EQUIPMENT TO PREVENT REPEATED OR PROLONGED SKIN CONTACT WITH THIS
SUBSTANCE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING, DRINKING OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
INDUSTRIAL FUEL OIL. THIS MATERIAL IS CONSIDERED TO BE A WATER
POLLUTANT AND RELEASES OF THIS PRODUCT SHOULD BE PREVENTED FROM
CONTAMINATING SOIL AND WATER AND FROM ENTERING DRAINAGE AND SEWER
SYSTEMS .
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:>350F,>177C
Vapor Pres:1
Spec Gravity:0.84
Viscosity:1.9 CST @ 40C
Solubility in Water:NEGLIGIBLE
Appearance and Odor:PALE YELLOW LIQUID, CHARACTERISTIC HYDROCARBON ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:MAY BE IGNITED BY HEAT, SPARKS OR FLAME.
VAPORS MAY TRAVEL TO SOURCE OF IGNITION AND FLASH BACK; VAPOR
EXPLOSION HAZARD.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY RELEASE
HYDROCARBONS & HYDROCARBON DERIVATIVES (CARBON DIOXIDE, ORGANIC
ACIDS & ALDEHYDES).
==================== Disposal Considerations ====================
Waste Disposal Methods:UNDER EPA RCRA, IF THIS PRODUCT BECOMES A WASTE
MATERIAL INTENDED FOR DISPOSAL AND HAS A FLASH POINT BELOW 140F, IT
WOULD BE IGNITABLE HAZARDOUS WASTE (CODE D001). REFER TO LATEST EPA
OR STATE REGULAT IONS REGARDING PROPER DISPOSAL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:09-D5078-000, RESOLVE PROCARE TANNIN (SUPDAT)
CAGE:IO272
CAGE:IO272
CAGE:63180
============= Composition/Information on Ingredients =============
Ingred Name:GLYCOLS, POLYETHYLENE, MONO(P-NONYL PHENYL); (NONYL PHENOL
POLYETHYLENE GLYCOL)
CAS:26027-38-3
RTECS #:MD0906000
Fraction by Wt: 2.8%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:OXALIC ACID
CAS:144-62-7
RTECS #:RO2450000
Fraction by Wt: 0.8%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3/2 STEL
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHANOL, 2-BUTOXY-; (2-BUTOXYETHANOL)
CAS:111-76-2
RTECS #:KJ8575000
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM
Ingred Name:2-PROPANOL, 1-METHOXY-; (PROPYLENE GLYCOL MONOMETHYL ETHER)
CAS:107-98-2
RTECS #:UB7700000
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150 STEL
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: DO NOT GET IN EYES.
ANIMAL STUDIES HAVE CLEARLY DEMONSTRATED DOSE-RELATED ADVERSE EFTS
ON CNS, HEMATOPOIETIC TISSUES, BLOOD, KIDNEYS & LIVER ASSOCIATED
WITH ADMINISTERING OF ETHYLENE GLYC OL MONOBUTYL ETHER (EGBE).
(EXTRATED FROM DHHS (NIOSH) PUB NO. 90-118) .
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . SKIN:FLUSH W/COPIOUS
AMOUNTS OF WATER. CALL MD . EYES: IMMEDIATELY REMOVE CONTACT LEN
SES AND RINSE WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. GET
MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>200F,>93C
Extinguishing Media:USE WATER SPRAY, FOAM, DRY CHEMICAL OR CARBON
DIOXIDE, AS SUITABLE FOR THE SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:FOR SPILLS DUE TO RUPTURED CONTAINERS, FLUSH
WITH LARGE QUANTITIES OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:WARNING: DO NOT GET IN EYES. KEEP OUT
OF REACH OF CHILDREN.
Other Precautions:DO NOT MIX WITH BLEACH OR USE WITH OTHER CHEMICALS.
KEEP FROM FREEZING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED. NIOSH APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE REQUIRED.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR TRADE NAME/PART NO:CARPET SPOT CLEANER. PH:3.5-4.5.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:1.012
pH:SUPDAT
Evaporation Rate & Reference:1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, WATER WHITE LIQUID. SWEET PEACH ODOR.
Percent Volatiles by Volume:>95
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
DO NOT MIX WITH BLEACH OR USE WITH OTHER CHEMICALS.
Stability Condition to Avoid:KEEP FROM FREEZING.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE, AND FEDERAL
REGULATIONS. PLEASE ENCOURAGE STATE & LOCAL AUTH TO ESTABLISH A
RECYCLING PROGRAM SO THAT THIS CONTAINER CAN BE RECYCLED.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: 28-0111 BRUNING PD ACTIVATOR 22-761012
Cage: 0SL27
Proprietary Ind: Y
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 0SL27
=======================================================
Contractor Summary
=======================================================
Cage: 9Y119
Cage: 0SL27
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: ORAL LD50(RAT): 3500 MG/KG
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES: MAY CAUSE EXTREME IRRITATION/DAMAGE. SKIN: MAY CAUSE
EXTREME IRRITATION, BURNS, DERMATITIS. INHALATION: MAY CAUSE MARKED
IRRITATION OF NOSE, THROAT & LUNGS. INGESTION: MAY CAUSE DIGESTIVE TRACT
IRRITATION. AMES TESTS OF MIXTURE WERE NEGATIVE, INDICATING NO MUTAGENIC
ACTIVITY.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: IRRITATION, BURNS, ITCHING, DEFATTING,
DRYNESS OF THROAT.
First Aid: EYES: IRRIGATE W/LARGE AMOUNTS OF RUNNING WATER FOR 15 MINS. SKIN:
WASH W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: MOP/FLUSH W/WATER & BLOT W/TOWELS. WEAR
Waste Disposal Methods: INCINERATION, SMALL QUANTITIES MAY BE DILUTED &
FLUSHED DOWN DRAIN IAW/FEDERAL, STATE & LOCAL REGULATIONS.
Other Precautions: DON'T RUB EYES AFTER CONTACT W/FLUID. AVOID PUNCTURING
CONTAINERS. WHEN REPAIRING/SERVICING EQUIPMENT, USE SAME PRECAUTIONS FOR
HANDLING CONTAMINATED PARTS AS RECOMMENDED FOR FLUID.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point Text: 233F
Extinguishing Media: WATER, CO2, DRY POWDER.
Fire Fighting Procedures: WEAR A SCBA.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT REQUIRED UNLES FIGHTING FIRES.
Ventilation: MECHANICAL (GENERAL): SUFFICIENT TO PREVENT ODORS & TO HANDLE
HEAT PRODUCED BY PD COPY MACHINE USED.
Work Hygienic Practices: WASH THOROUGHLY AFTER HANDLING/CONTACT.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 216-650F
Vapor Pres: <1
Vapor Density: 3
Spec Gravity: 1.05
PH: 11
Solubility in Water: COMPLETE
Appearance and Odor: CLEAR, PALE YELLOW LIQUID W/NO DISTINCT ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: OPEN FLAME & HIGH TEMPS.
Materials To Avoid: STRONG ACIDS & OXIDIZING AGENTS.
Hazardous Decomposition Products: BY FIRE/REACTION W/STRONG OXIDIZING AGENTS:
OXIDES OF CARBON & NITROGEN.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: 28-0111 BRUNING PD ACTIVATOR 22-761012
Cage: 0SL27
Company Name: OCE-BRUNING INC
Street: 1800 BRUNING DRIVE W
Zipcode: 60143
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: EYES: IRRITATION OR DAMAGE. SKIN: ITCHING, IRRITATION,
BURNS, DEFATTING, & DERMATITIS. INHALATION: DRYNESS OF THROAT. NOSE,
THROAT, & LUNG IRRITATION. INGESTION: DIGESTIVE TRACT IRRITATION.
EYES:
IRRITATION OR EYE DAMAGE. SKIN: ITCHING, IRRITATION, BURNS, DEFATTING, &
DERMATITIS. INHALATION: DRYNESS OF THE THROAT. NOSE,THROAT, & LUNG
THROAT. INGESTION: DIGESTIVE TRACT IRRITATION.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DESIGN HIGGINS WATERPROOF COLOR DRAWING INK, 44117
CAGE:07103
CAGE:32988
CAGE:07103
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NONE.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . EYES:FLUSH W/WATER FOR AT LEAST 15 MINUTES. SKIN:WASH
W/SOAP & WATER. INGEST:IF VERY LARGE QUANTITIES INGESTED, SEE MD.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
NON-FLAMMABLE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . NON-FLAMMABLE.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH W/WATER. NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NOT APPLICABLE.
Work Hygienic Practices:WASH W/SOAP & WATER.
Supplemental Safety and Health
SPEC GRAV:1.02-1.03 (H*2O=1).
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:SUPP DATA
Solubility in Water:100%
Appearance and Odor:COLORED INKS; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT FEDERAL, STATE & LOCAL REGULATIONS.
NON-HAZARDOUS WASTE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:AMMONIUM HYDROXIDE
CAGE:37940
CAGE:37940
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIUM HYDROXIDE (CERCLA)
CAS:1336-21-6
RTECS #:BQ9625000
Fraction by Wt: 58%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 42%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RAT LD50:350 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CORROSIVE! INHALATION CAN CAUSE
COUGHING, CHOKING, & INFLAMATION OF THE RESPIRATORY TRACT.
SWALLOWING CAN CAUSE BURNS TO MOUTH & GI TRACT. EYE/SKIN: LIQUID
CONTACT CAN CAUSE SEVERE BURNS, CORNE AL SCARS & GLAUCOMA DAMAGE,
DEEP ULCERS& DISCOLOR SKIN OR SKIN BURNS WITH VESICATION. CHRONIC:
NO INFORMATION FOUND.
Effects of Overexposure:INHALATION:CORROSIVE! VAPORS CAN CAUSE
COUGHING, CHOKING, & INFLAMATION OF THE RESPIRATORY TRACT.
INGESTION: CORROSIVE! CAN CAUSE BURNS TO MOUTH & GI TRACT. MAY
ERODE TEETH. LARGE QUANTITY MAY CAUSE D EATH. EYE/SKIN:CORROSIVE!
CAN CAUSE SEVERE BURNS, DAMAGE,DEEP ULCERS & DISCOLOR SKIN. SPLASH
CAUSES SEVERE DAMAGE TO EYE
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING EYE
DISORDERS OR IMPAIRED RESPIRATORY FUNCTION MAY BE MORE SUSCEPTIBLE
TO THE EFFECTS OF THIS MATERIAL.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING.FLUSH WITH WATER.CALL A
PHYSICIAN FOR BURNS/IRRITATION. INHALATION:REMOVE TO FRESH AIR &
RESTORE BREATHING IF NECESSARY. EYES:IMMEDIATELY FLUSH WITH RUNNING
WATER FOR AT LEAST 15 MINUTES WHILE HOLDING EYELIDS OPEN.CALL A
PHYSICIAN. INGESTION: DO NOT INDUCE VOMITING. IF CONSCIOUS, GIVE
2-3 GLASSES OF WATER. IMMEDIATELY REPORT TO A DOCTOR & POISON
CONTROL CENTER.
===================== Fire Fighting Measures =====================
Autoignition Temp:Autoignition Temp Text:1204F
Lower Limits:16
Upper Limits:27
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING FIRE. USE
WATER SPRAY TO BLANKET FIRE, COOL FIRE EXPOSED CONTAINERS, FLUSH
SPILL..
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE GEAR. COOL FIRE EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:NOT CONSIDERED TO BE AN EXPLOSION HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE & EVACUATE AREA.USE PROTECTIVE
CLOTHG & RESP PROTCTION FROM VAPORS.CONTAIN & RECOVER LIQ WHEN
POSSIBLE. SPILLS MAY BE ABSORBD WITH INERT MATERIAL & COLLECTD FOR
DISPOSAL IN RCRA FACLTY;NEUTR ALIZE SPILL W/DIL HCL/H2SO4 &
DISCHARGETO SEWER
Neutralizing Agent:DILUTE HYDROCHLORIC ACID/SULFURIC ACID
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN TIGHTLY CLOSED CONTAINERS AT
COOL, DRY,VENTILATED PLACE.PROTECT AGAINST PHYSICAL DAMAGE.PROTECT
FM DIRECT SUNLIGHT.WASH THOROUGHLY AFTER HANDL
Other Precautions:AVOID BREATHING VAPORS/FUME/MIST. USE WITH ADEQUATE
VENTILATION. KEEP CONTAINRS CLOSED. DO NOT GET IN EYES, ON SKIN, OR
ON CLOTHING; THIS IS CLASSIFIED AS POISON UNDR THE FED CAUSTIC
POISON ACT; CLOSE CAP AFTER USE. NEVER TRY TO SMELL NH3.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF THE TLV EXCEEDED, ADUST/MIST RESPIRATOR WITH
ALTERNATELY,A SUPPLIED AIR FULL PIECE RESPIRATOR OR AIRLINED HOOD
MAY BE WORN.
Ventilation:A SYSTEM OF LOCAL AND GENERAL EXHAUST IS RECOMMENDED.LOCAL
EXHAUST IS GENERALLY PREFERRED TO MAINTN EMMISSION BELOW TLV.
Other Protective Equipment:FULL PROTECTIVE CLOTHING,INCLUDNG BOOTS,
WASH STATIO
Work Hygienic Practices:OBSERVE GENERAL INDUSTRIAL HYGIENE
PRACTICE.KEEP AREA CLEAN.WASH THOROGHLY AFTER EACH USE OR
HANDLING.AVOID CONTACT.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:B1
Boiling Pt:=36.C, 96.1F
Melt/Freeze Pt:=-72.C, -97.6F
Vapor Pres:115
Vapor Density:0.60
Spec Gravity:0.9
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS SOLUTION; AMMONIA ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS,ACROLEIN,DIMETHYL SULFATE,HALOGENS,SILVER NITRATE,PROPYLENE
OXIDE,NITROMETHANE,SILVER OXIDES,SILVER PERMANGANATE..
Stability Condition to Avoid:STABLE UNDER NORMAL CONDITIONS OF USE AND
STORAGE.
Hazardous Decomposition Products:OXIDES OF NITROGEN, AMMONIA WHEN
HEATED TO DECOMPOSITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE NEUTRALIZED SPILL/WASTE LIQ TO SEWERS.
REGULATIONS FOR PH,AMMONIA CONTENT AND SALTS FOR EFFLUENTS MUST BE
CONSIDERED.DISPOSE OF THE ABOSRBED SPILL IN AN RCRA APPROVED
FACILITY. ENSURE COMPLI ANCE W/LOCAL,FED & STATE
REGS;CWA/CERCLARQ:1000LB
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CAT#:A253100 PICRIC ACID,WET,WITH NOT LESS THAN 10% WATER
Preparer's Name:GASTON L. PILLORI
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:PICRIC ACID (SARA 313)
CAS:88-89-1
RTECS #:TJ7877000
Fraction by Wt: <90.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S, 0.1 MG/M3
ACGIH TLV:0.1 MG/M3; 9596
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: >10.0%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ALCOHOL MAY ENHANCE TOXIC
EFFECTS.INHAL:IRRIT/NEPHROTOXIN/HEPATOTOXIN.HI DUST CONC IRRIT RESP
TRACT,EFFECTS OF
BLOOD,LIVE/KIDNEY.SKIN:IRRIT/SENS/NEPHROTOXIN/HEPATOTOXIN.IRRIT,SEN
S DERM,EFFECTS ON BLOO D/LIV/KID.ECZEMA,SENS DERM,ABSORPT LIV/KID
DMG.EYE:IRRIT.SEVERE CONJUCT,PALPEBRAL EDEMA,KERATITIS,YELLOW
VISION(SUPPLE)
Explanation of Carcinogenicity:PER MSDS:CARCINOGEN STATUS:NONE.
Effects of Overexposure:INHAL:COUGH,SORE THROAT,LUNG DMG(TEMP
COMA,WEAK,MYALGIA,ANURIA,POLYURIA).YELLOW TEETH
STAINS,SKIN,CONJUN,HAIR,PRURITIS,SKIN ERUPTIONS.SKIN:ECZEMA,SENS
DERM,PAPULES/VESICLE FORM TO DESQUAMATION.SKIN/HA IR
YELLOW.INGEST:HEAD,NAU,VOMIT,DIARR,SKIN/EYE YELLOW,MUSC
PAIN,HEMORRHAGIC NEPHRITIS,ALBUMINEUREA,POLYUREA,JAUN,DEATH.
Medical Cond Aggravated by Exposure:TARGET
EFFECTS:SENS-DERM,NEPHROTOXIN,HEPATOTOXIN,POISONING MAY AFFECT
BLOOD,EYE,METABOLIC RATE.@INCR RISK FRM EXPO:PERSONS W/HISTORY
W/ASTHMA.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE TO FRESH AIR IMMED.STOP BREATH ART
RESP.SKIN:REMOVE CONTAM CLOTH/SHOES IMMED.WASH W/SOAP/MILD
DETERGT/LOTS OF H2O 15-20MINS.GET MED ATTN.EYE:WASH IMMED W.GL ATMS
OF H2O/NORMAL SALINE,LIFTIN G LIDS 15-20MINS.GET MED ATTN
IMMED.INGEST:CONSC REMOVE POISON BY GASTRIC LAVAGE OR EMESIS W/ACT
CHARCOAL.RESP SHALLOW/ANOXIA GIVE OXY.GET MED ATTN.NOT SPECIFIC
ANTIDOTE.TREAT SYMPTOMATICALLY/SUPPORTV
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:302F,150C
Autoignition Temp:Autoignition Temp Text:NP
Lower Limits:NP
Upper Limits:NP
Extinguishing Media:FLOOD W/WATER,IF NOT WATER AVAILABLE USE DRY
CHEMICAL OR DIRT.
Fire Fighting Procedures:FIREFIGHTING/OTHER IMMED DANGEROUS TO
LIFE/HEALTH CONDITIONS:ANY SCBA W/FULL FCPIECE OPERATED IN
PRESSURE-DEMAND OR OTHER +PRESS MODE;SUPPL AIR W/AUX SCBA.
Unusual Fire/Explosion Hazard:EXPLODES ON HEATING >572F/300C.DANGEROUS
FIRE/EXPLO HAZ WHEN EXPO TO HEAT/FLAME/SHOCK/FRICTION.H2O CONTENT
>10% MATL DANGEROUS EXPLO.PROD MUCH LESS (SUPPLEMENT)
================== Accidental Release Measures ==================
Spill Release Procedures:SHUT OFF IGN SOURCES.DONT TOUCH SPILL.SM-FLUSH
AREA W/FLOODING AMTS OF WATER.LG-WET DOWN W/WATER,DIKE FOR LATER
DISPO.NO SMOKING/FLAMES/FLARES IN HAZ AREA!KEEP UNNECESSARY PEOPLE
AWAY.ISOLATE HAZ AREA & DENY ENTRY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:OBSERVE ALL FED/STATE/LOC REGS WHEN
STORE/DISPO OF SUBJ.FOR ASSIST CONTACT DISTRICT DIR OF EPA.STORE IN
COOL DRY PLACE IN TIGHTLY CLSD CNTNR.
Other Precautions:AVOID EXPO TO HEAT/SPARK/OPN FLAM/EXPO TO SHOCK.DONT
ATTEMPT TO REDISSOLVE MATL THAT HAS CRYSTALLIZED OUT OF
SOLN.CONTACT LOC BOMB SQUAD FOR DISPO.PROTECT AGAINST PHYS
DMG.STORE IN PERM MAGAZINE.MATL EXPLO WHEN DRY.AVOID
OVERHEAT/SHOCK/IGN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESP/MAX USE CONCE RECOMMENDED BY US DEPT OF
HEALTH/HUMAN SERV,NIOSH POCKET GUIDE,NIOSH,DEPT OF LABOR.SPEC RESP
SELECTED MUST BE BASED ON CONTAM LEVELS IN WORKPLACE,NOT EXCEED
WORK LIMITS OF RESP,JOIN TLY APPROV BY NIOSH/MSHA.
Ventilation:PROVIDE LOC EXHAUST VENTILATION SYSTEM TO MEET PUBLISEHD
EXPO LIMITS.
Other Protective Equipment:PROTECTIVE CLOTH NOT REQUIRED.AVOID REP/PROL
CONTACT W/THIS SUBSTANCE.EYEWASH FOUNTAIN/QUICK DRENCH SHOWER
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE/EXPLO:DANGEROUS THAN DRY MATL. HEALTH:TEMP CORN
INJURY.INGEST:NEPHROTOXIN/HEPATOXIN.1-5G INGEST HEAD,BITTER
TASTE,VERTIGO,SEVE GASTROENTERITIS,DEATH FRM RENAL
LESIONS,ANURAI,JAUNDICE,COMA,CONVULS .LIV/KID DMG.
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:NP
Melt/Freeze Pt:M.P/F.P Text:252F,122C
Decomp Temp:Decomp Text:NP
Vapor Pres:.0075@122C
Vapor Density:7.9
Spec Gravity:1.767
pH:NP
Viscosity:NP
Evaporation Rate & Reference:NP
Solubility in Water:1.4% @20C, MODERATE
Appearance and Odor:ODORLESS SLURRY OF YELLOW CRYSTALS
Percent Volatiles by Volume:NP
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AL+H2O,AMMONIA,BASES,BOMSUT MALT,CONCRETE,CU,PB,HG,METALS/SALTS,STRONG
OXIDIZ,RED MATL,UREA PERCHLORATE,ZN.
Stability Condition to Avoid:MAY DETONATE IN HEAT OF FIRE.MALT EXPLO
>572F/300C.H2O CONTENT <10% MUCH MORE SUSCEPT TO DETONATION & MAY
BE SHOCK SENS.
Hazardous Decomposition Products:THERMAL DECOMPO PRODUCTS MAY INCLUDE
TOXIC OXIDES OF CARBON AND NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:SUBJ TO SARA SEC 313 REPORTING.DISPO OF IAW
W/STD APPLICABLE TO GENERATORES OF HAZ WASTE 40CFR262.EPA HAZ
WASTE#:D001,D003.100LB CERCLA SEC 103 RQ.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: INTERCARE 755 BLACK, ESY999
Cage: 0TZS5
=======================================================
Contractor Summary
=======================================================
Cage: 0TZS5
=======================================================
Item Description Information
=======================================================
=======================================================
Ingredients
=======================================================
Cas: 21645-51-2
RTECS #: BD0940000
% low Wt: 25.
% high Wt: 50.
------------------------------
Cas: 110-43-0
RTECS #: MJ5075000
% low Wt: 10.
% high Wt: 25.
OSHA PEL: 465 MG/M3;100 PPM
ACGIH TLV: 233 MG/M3;50 PPM
ACGIH STEL: NOT ESTABLISHED
------------------------------
Cas: 107-87-9
RTECS #: SA7875000
% low Wt: 1.
% high Wt: 10.
OSHA PEL: 700 MG/M3;200 PPM
ACGIH TLV: 705 MG/M3;200 PPM
ACGIH STEL: 881 MG/M3;250 PPM
------------------------------
Cas: 1330-20-7
RTECS #: ZE2100000
% low Wt: 1.
% high Wt: 10.
OSHA PEL: 435 PPM
OSHA STEL: 650 PPM, S
ACGIH TLV: 434 MG/M3;100 PPM
ACGIH STEL: 651 MG/M3;150 PPM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 1333-86-4
RTECS #: FF5800000
% low Wt: 1.
% high Wt: 10.
OSHA PEL: 3.5 MG/M3
ACGIH TLV: 3.5 MG/M3
ACGIH STEL: NOT ESTABLISHED
------------------------------
Cas: 64742-95-6
RTECS #: WF3400000
% low Wt: 1.
% high Wt: 10.
ACGIH TLV: 100 PPM
------------------------------
Cas: 71-36-3
RTECS #: EO1400000
% low Wt: 1.
% high Wt: 10.
OSHA PEL: 300 MG/M3;100 PPM
OSHA STEL: C50 PPM, S
ACGIH TLV: NOT ESTABLISHED
ACGIH STEL: C152 MG/M3;C50 PPM
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 25551-13-7
RTECS #: DC3220000
% low Wt: 1.
% high Wt: 10.
ACGIH TLV: 123 MG/M3;25 PPM
ACGIH STEL: NOT ESTABLISHED
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: YES
OSHA: NO
Effects of Exposure: ACUTE: INHALATION: CAUSES NOSE AND THROAT IRRITATION.
HARMFUL IF INHALED. MAY AFFECT THE BRAIN OR NERVOUS SYSTEM CAUSING DIZZINESS,
HEADACHE OR NAUSEA. EYE CONTACT: CAUSES IRRITATION. SKIN CONTACT: CA USES
IRRITATION. CAN BE ABSORBED THROUGHSKIN. MAY CAUSE ORGAN DAMAGE. INGESTION:
MAY BE FATAL IF SWALLOWED AND MAY CAUSE ORGAN DAMAGE. CHRONIC: CARBON BLACK
HAS BEEN DETERMINED BY IARC TO CAUSE CANCER IN LABORATORY ANIMALS AND CAN BE
A POSSIBLE HUMAN CARCINOGEN. NOTICE: REPORTS HAVE ASSOCIATED REPEATED AND
PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN AND
NERVOUS SYSTEM DAMA GE. INTENTIONAL MISUSE (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: CARBON BLACK (1333-86-4): IARC MONOGRAPHS ON
THE EVALUATION OF THE CARCINOGENIC RISK OF CHEMICALS TO MAN, VOL 65, PG 149,
1996: GROUP 2B.
Signs And Symptions Of Overexposure: HLTH HAZ: BY DELIBERATELY CONCENTRATING
AND INHALING THE CONTENTS MAY BE HARMFUL OR FATAL.
First Aid: IN ALL CASES OF DOUBT, OR WHEN SYMPTOMS PERSIST, SEEK MEDICAL
ATTENTION. INHALATION: REMOVE TO FRESH AIR. IF DISCOMFORT IS PRESENT OR
BREATHING IS ABSENT GET MEDICAL ATTENTION IMMEDIATELY. EYES: FLUSH
IMMEDIATELY WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES UNTIL IRRITATION
SUBSIDES. IF IRRITATION PERSISTS, GET MEDICAL ATTENTION. SKIN: FLUSH WITH
LARGE AMOUNTS OF WATER. USE SOAP IF AVAILABLE. REMO VE SEVERELY CONTAMINATED
CLOTHING (INCLUDING SHOES) AND WASH BEFORE REUSE. IF IRRITATION PERSISTS, GET
MEDICAL ATTENTION. INGESTION: DO NOT INDUCE VOMITING. KEEP AT REST. GET
PROMPT MEDICAL ATTENTION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: CONTAIN SPILLED LIQUID WITH SAND OR EARTH. DO NOT USE
COMBUSTIBLE MATERIALS SUCH AS SAWDUST. ABSORB SPILL WITH INERT MATERIAL
(E.G., DRY SAND OR EARTH), THEN PLACE IN A CHEMICAL WASTE CONTAINER.
Waste Disposal Methods: DISPOSE OF I/A/W LOCAL, STATE AND FEDERAL REGULATIONS.
DO NOT INCINERATE UNOPENED CONTAINERS.
Handling And Storage Precautions: KEEP CONTAINER CLOSED. LOOSEN CLOSURE
CAUTIOUSLY BEFORE OPENING. STORE IN A COOL, WELL VENTILATED PLACE AWAY FROM
INCOMPATIBLE MATERIALS. KEEP AWAY FROM HEAT, SPARKS AND FLAMES. PROTECT
MATERIAL FROM DIRECT SUNLIGHT. DO NOT BREATHE VAPORS OR SPRAY MIST.
Other Precautions: GROUND AND BOND CONTAINERS WHEN TRANSFERRING MATERIALS.
EMPTY CONTAINERS MAY RETAIN HAZARDOUS PROPERTIES. FOLLOW ALL MSDS/LABEL
WARNINGS, EVEN AFTER CONTAINER IS EMPTIED.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point: =22.8C, 73.F
Lower Limits: 1%
Extinguishing Media: FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT
(FP N). ISOLATE FROM HEAT, SPARKS, ELECTRICAL EQUIPMENT AND OPEN FLAME.
CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT. IN THE ABSENCE
OF ELECTRICITY, A WATER SPRAY (A FOG NOZZLE IS PREFERRED) MAY BE USED TO COOL
CONTAINERS.
Unusual Fire/Explosion Hazard: OSHA CLASSIFICATION: FLAMMABLE LIQUID - CLASS
IC. DECOMPOSITION AND COMBUSTION PRODUCTS MAY BE TOXIC.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF YOU EXPERIENCE EYE WATERING, HEADACHE OR DIZZINESS
OR IF AIR MONITORING DEMONSTRATES VAPOR/MIST LEVELS ARE ABOVE APPLICABLE
LIMITS, WEAR AN APPROPRIATE PROPERLY FITTED NIOSH APPROVED RESPIRATOR DUR ING
AND AFTER APPLICATION. FOLLOW RESPIRATOR MANUFACTURER'S DIRECTIONS FOR
RESPIRATOR USE.
Ventilation: PROVIDE SUFFICIENT VENT, IN VOL & PATTERN, TO: A) KEEP TLV OF
HAZ INGS BELOW LIMS SPECIFIED IN INGS; B) REMOVE VOLATILES PRDCD DURING CURE
& DECOMP (SUPP DATA)
(FP N).
Other Protective Equipment: EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA (FP N). CLOTHING: AS NEEDED, USE BODY PROTECTION TO AVOID CONTACT
WITH PRODUCT.
Supplemental Safety and Health: VENT: DECOMPOSITION PRODUCTS PRODUCED DURING
WELDING OR CUTTING ON SURFACES COATED WITH THIS PRODUCT.
=======================================================
Physical/Chemical Properties
=======================================================
Boiling Point: =100.6C, 213.F
Vapor Density: HVR/AIR
Spec Gravity: 1.161
Evaporation Rate & Reference: SLOWER THAN ETHER
Appearance and Odor: LIQUID.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: THIS PRODUCT IS STABLE
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: MAY PRODUCE HAZARDOUS FUMES WHEN HEATED TO
DECOMPOSITION AS IN WELDING. FUMES MAY PRODUCE CARBON DIOXIDE AND CARBON
MONOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: HAZARDOUS POLYMERIZATION WILL NOT OCCUR.
=======================================================
Toxicological Information
=======================================================
Toxicological Information: THERE IS NO DATA AVAILABLE ON THE PRODUCT ITSELF.
N-BUTYL ALCHOL: THERE IS A RISK OF ABORPTION THROUGH UNBROKEN SKIN.
=======================================================
Ecological Information
=======================================================
Ecological: THERE IS NO DATA AVAILABLE ON THE PRODUCT ITSELF.
=======================================================
=======================================================
Transport Information: DOT (DEPARTMENT OF TRANSPORTATION): PROPER SHIPPING
NAME: PAINT. HAZARD CLASS: FLAMMABLE LIQUID, 3. UN NUMBER: UN1263. PACKING
GROUP: PACKING GROUP II.
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: CERCLA (COMPREHENSIVE RESPONSE COMPENSATION, AND
LIABILITY ACT): MFR RECOMMENDS YOU CONTACT YOUR LOCAL AUTHORITIES TO
DETERMINE IF THERE MAY BE OTHER LOCAL REPORTING REQUIREMENTS. SARA TITLE III
(SUPE RFUND AMENDMENTS AND REAUTHORIZATION ACT): SECTION 302 REPORTABLE
INGREDIENTS: N-BUTYL ALCOHOL (71-36-3) & XYLENE, MIXTURE OF ISOMERS
(1330-20-7).
Federal Regulatory Information: TSCA (TOXIC SUBSTANCE CONTROL ACT): COMPONENTS
OF THIS PRODUCT ARE LISTED ON THE TSCA INVENTORY. W CLASSIFICATION: CLASS B,
DIVISION 2. OSHA REPORTABLE HAZARDOUS COMPONENTS (20 CFR 1910.1200): ALU
MINUM HYDROXIDE - 25-50% BY WT (21645-51-2); METHYL N-AMYL KETONE - 10-25% BY
WT (110-43-0); METHYL N-PROPYL KETONE - 1-10% BY WT (107-87-9); XYLENE,
MIXTURE OF ISOMERS - 1-10% BY WT (1330-20-7); CARB ON - 1-10% BY WT
(1333-86-4); AROMATIC HYDROCARBONS - 1-10% BY WT (64742-95-6); N-BUTYL
ALCOHOL - 1- 10 % BY WT (71-36-3); TRIMETHYL BENZENE - 1-10% BY WT
(25551-13-7).
State Regulatory Information: CALIFORNIA PROPOSITION 65: WARNING: THIS PRODUCT
CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE BIRTH DEFECTS
OR OTHER REPRODUCTIVE HARM; NONE KNOWN. WARNING: THIS PRODUCT CONTAINS A CH
EMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER; CARBON BLACK.
=======================================================
HAZCOM Label
=======================================================
Product ID: INTERCARE 755 BLACK, ESY999
Cage: 0TZS5
Company Name: INTERNATIONAL PAINT INC
Street: 6001 ANTOINE DRIVE
Zipcode: 77091
Label Required IND: Y
Date Of Label Review: 11/10/1999
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE! ACUTE: INHAL: CAUSES NOSE & THROAT
IRRIT. HARMFUL IF INHALED. MAY AFFECT THE BRAIN/NERV SYS CAUSING DIZZ,
HDCH/NAUS. EYE CONT: CAUSES IRRIT. SKIN CONT: CAUSES IRRIT. CAN BE ABSORBED
THROUG H SKIN. MAY CAUSE ORGAN DMG. INGEST: MAY BEFATAL IF SWALLOWED AND MAY
CAUSE ORGAN DAMAGE. CHRONIC: CANCER HAZARD. CONTAINS CARBON BLACK WHICH IS
LISTED AS AN ANIMAL LUNG CARCINOGEN (FP N). NOTICE: REP ORTS HAVE ASSOCIATED
REPEATED AND PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN AND NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING & INHALING THE CONTEN TS MAY BE HARMFUL/FATAL.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:155 8931,METAL ETCH RESIST THINNER
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 97.5%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:INHAL:HI-VAPOR CONC,ANESTHETIC W/HEADCH,DIZ &
NAUSEA;EYE:LIQUID IRRITATES;SKIN:DEFAT & CRACKING
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOSURE & GET MEDICAL ATTENTION;EYES:FLUSH
IMMEDIATELY W/PLENTY OF WATER & GET MEDICAL ATTENTION;SKIN:FLUSH
WITH PLENTY OF WATER.
===================== Fire Fighting Measures =====================
Flash Point:84F/29C TCC
Lower Limits:1.1
Upper Limits:7.0
Extinguishing Media:CARBON DIOXIDE,DRY FOAM
Fire Fighting Procedures:NONE INDICATED BY MFR
Unusual Fire/Explosion Hazard:NONE INDICATED BY MFR.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP WITH ABSORBENT MATERIAL.STATE & LOCAL
EFFLUENT LAWS TAKE PRECEDENCE.
======================Handling and Storage ======================
Handling and Storage Precautions:MFR INDICATES NONE.
Other Precautions:WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AN APPROVED ORGANIC VAPOR,FOR EMERGENCY USE ONLY
Ventilation:LOCAL EXHAUST & GENERAL MECHANICAL REQUIRED
Other Protective Equipment:AS DICTATED BY LOCAL PROCEDURES TO PREVENT
SKIN CONTACT
Supplemental Safety and Health
INFORMATION EFFECTIVE ON MSDS 3/4/77
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:136-139F
Vapor Pres:<10
Vapor Density:3.66
Spec Gravity:0.8627
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WATER-WHITE LIQUID;PETROLEUM ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CORROSIVES & OXIDIZERS
Stability Condition to Avoid:SOURCES OF IGNITION
Hazardous Decomposition Products:BURNING MAY RESULT IN EVOLUTION OF CO
& CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN-TREAT AS ORGANIC SOLVENTS;STATE & LOCAL
EFFLUENT LAWS TAKE PRECEDENCE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:KAO-TEX 2000 TAPE
CAGE:0UHC8
CAGE:0UHC8
============= Composition/Information on Ingredients =============
Ingred Name:REFRACTORY FIBERS, ALUMINOSILICATE; (REFRACTORIES, FIBERS,
ALUMINOSILICATE)
CAS:142844-00-6
Fraction by Wt: 70-80%
Other REC Limits:1 FIBER/CC (MFR)
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:N/K
Ingred Name:ORGANIC BINDER; (ORGANIC CARRIER/BINDER)
Fraction by Wt: <20%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE
CAS:14464-46-1
RTECS #:VV7325000
Fraction by Wt: N/K (F)
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.05 MG/M3 RDUST
Ingred Name:ALUMINUM SILICATE; (MULLITE)
CAS:1302-76-7
RTECS #:BD1450000
Fraction by Wt: N/K (F)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:PLEURA (LINING OF CHEST WALL & LUNG). IN CONTRAST,
HAMSTERS SIMILARLY EXPOS DEVEL INTERSTITIAL FIBROSIS & (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:PLEURAL CANCER, BUT NO LUNG CANCER. PLEURAL FIBROSIS
& MESOTHELIOMA WERE SEEN IN SINGLE RAT IN MID-DOSE (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:(9 MG/M3) GRP. PULM FIBROSIS WAS OBSERVED AT 9 & 16
MG/M3. AS MFRD, RCF PRODS ARE ALUMINOSILICATES WHICH (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:MAY TRANSFORM UPON HEATING AT TEMPS >1800F TO MULLITE
& CRISTOBALITE (FORM OF CRYSTALLINE SILICA). PRLNG/ (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:RPTD INHAL OF RESPIRABLE FREE CRYSTALLINE SILICA DUST
MAY CAUSE DELAYED LUNG INJURY (SILICOSIS). FOR MORE (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:SPECIFIC INFORMATION CONTACT NEHC .
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH:INCOMPLETE, INACCURATE/OTHERWISE INAPPROP.
IF DISCARDED IN ITS PURCHASED FORM, THIS PROD WOULD (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:NOT BE HAZ WASTE EITHER BY LISTING/BY CHARACT.
HOWEVER, UNDER RCRA, IT IS RESPONSIBILITY OF PROD USER TO (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:DETERM AT TIME OF DISP WHETHER MATL CNTNG/DERIVED
FROM PROD SHOULD BE CLASSIFIED AS HAZ WASTE (40 CFR 261.20-24).
RTECS #:9999999ZZ
Ingred Name:RESP PROT:PROVIDING RESPS TO EMPLOYEES (ESP NEG PRESS
TYPE), EMPLOYERS SHOULD 1)MONITOR FOR AIRBORNE FIBERS & (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:RESPIRABLE CRISTOBALITE CONCS USING NIOSH METH
7400(B) & 7500 RESPECTIVELY & SELECT APPROP NIOSH APPRVD (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:RESP PROT BASED UPON RSLTS OF THAT MONITORING,
2)HAVE WORKERS EVAL BY MD TO DETERM WORKERS' ABILITY TO (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:WEAR NIOSH APPRVD RESPS & 3)IMPLEMENT NIOSH RESP
PROT TRAINING PROGRAMS. USE NIOSH APPRVD RESPS, IN (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:COMPLIANCE W/OSHA RESP PROT STD 29 CFR 1910.134 & 29
CFR 1926.103, FOR PARTICULAR HAZ/AIRBORNE CONCS TO (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:BE ENCOUNTERED IN WORK ENVIRONMENT. FOR A COMPLETE
LISTING OF SPECIFIC RESPS CONTACT NEHC .
RTECS #:9999999ZZ
Ingred Name:HYGIENE PRACT:YOU VACUUM YOUR CLOTHES W/HEPA FILTERED
VACUUM BEFORE LEAVING THE WORK AREA.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE CONT:PHYSICAL IRRIT-INFLAMM.
SKIN CONT:PHYSICAL IRRIT-RASH. INGEST:MAY CAUSE TEMPORARY IRRIT TO
GI TRACT. INHAL:IRRIT/SORENESS IN THROAT, NOSE & RESP TRACT.
CHRONIC: EPIDEMIOLOGIC INVESTIGAT IONS OF RCF PRODUCTION WORKERS
FOUND PLEURAL PLAQUES (THICKENING ALONG CHEST WALL) HAVE BEEN
OBSERVED (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-CRISTOBALITE:IARC
MONOGRAPHS, SUPP, VOL 7, PG 341, 1987:GRP 2A. NTP 7TH ANNUAL REPORT
ON (SUPP DATA)
Effects of Overexposure:HLTH HAZ:IN SM NUMBER OF EMPLOYEES WHO HAD LONG
DURATION OF EMPLOYMENT. CERAMIC FIBER, FIBROUS GLASSWOOL & MINERAL
WOOL (ROCKWOOL & SLAGWOOL) POSS HUMAN CARCINS & SUFFICIENT EVID OF
CARCIN IN EXPTL AN IMALS (MFR). IN LIFETIME NOSE-ONLY INHAL STUDY,
RATS EXPOS TO 30 MG/M3 DEVEL PROGRESSIVE LUNG DMG (INTERSTITIAL
(SUPDAT)
Medical Cond Aggravated by Exposure:DUST & RESPIRABLE FIBERS FROM THIS
PRODUCT MAY AGGRAVATE EXISTING CHRONIC LUNG CONDITIONS SUCH AS
BRONCHITIS, EMPHYSEMA & ASTHMA.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES.
DO NOT RUB EYES. SKIN:WASH AFFECTED AREA GENTLY W/SOAP & WATER.
SKIN CREAM OR LOTION AFTER WASHING MAY BE HELPFUL. INGEST:DO NOT
INDUCE VOM ITING; DRINK PLENTY OF WATER. INHAL:REMOVE AFFECTED
PERSON TO CLEAN FRESH AIR. IF BREATHING IS DIFFICULT, HAVE TRAINED
PERSON ADMINISTER OXYGEN. IF ANY OF SYMPS PERSIST, SEEK MED ATTN
IMMED.
===================== Fire Fighting Measures =====================
Flash Point:300F,149C
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE TO THE
SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID CREATING AIRBORNE DUST. FOLLOW ROUTINE
HOUSEKEEPING PROCS. VACUUM ONLY W/HEPA FILTERED EQUIP. IF SWEEPING
IS NEC, USE A DUST SUPPRESSANT & PLACE MATL IN CLSD CNTNRS. DO NOT
GOGGS(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BRTHG FIBER PARTICULATES & DUST.
THIS PROD IS STABLE UNDER ALL CNDNS OF STOR. STORE IN ORIGINAL
FACTORY CNTNR IN DRY AREA.
Other Precautions:KEEP CNTNR CLSD WHEN NOT IN USE. LIM USE OF POWER
TOOLS UNLESS IN CONJUNCTION W/LOC EXHST. USE HAND TOOLS WHENEVER
POSS. FREQUENTLY CLEAN WORK AREA W/HEPA FILTERED VACUUM/WET
SWEEPING TO MIN ACCUM OF DEBRIS. DO NOT USE COMPRESSED (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN IT IS NOT POSS/FEASIBLE TO REDUCE AIRBORNE
FIBERS & DUST LEVELS BELOW PEL/REG THRU ENGINEERING CONTROLS/UNTIL
THEY ARE INSTALLED, EMPLOYEES ARE ENCOURAGED TO USE GOOD WORK
PRACTICES TOGETHER W/NI OSH APPRVD RESP PROT. BEFORE (ING 14)
Ventilation:USE ENGINEERING CONTROLS SUCH AS VENT & DUST COLLECTION
DEVICES TO REDUCE AIRBORNE FIBER CONCS TO LOWEST (SUPP DATA)
Other Protective Equipment:ANSI APPROVED EYE WASH FOUNTAIN & DELUGE
SHOWER . WEAR FULL BODY, LONG SLEEVED, LOOSE-FITTING CLOTHING &
HAT.
Work Hygienic Practices:WASH WORK CLOTHES SEPARATELY FROM OTHER CLTHG.
RINSE WASHER AFTER USE. IF YOU TAKE WORK CLTHG HOME, IT IS REC (ING
20)
Supplemental Safety and Health
MP:>3200F,>1768C. EXPLAN OF CARCIN:CARCINS, 1994:ANTIC TO BE CARCIN.
SPILL PROC:& NIOSH APPRVD RESP. AVOID CLEAN-UP PROCS THAT COULD
RSLT IN WATER POLLUTION. OTHER PREC:AIR FOR CLEAN-UP. VENT:ATTAINAB
LE LEVEL. GOOD VENT SHOULD BE PROVIDED DURING INITIAL HEATING. EFTS
OF OVEREXP:FIBROSIS) & CANCERS OF LUNG & OF (ING 5)
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:SUPP DATA
Spec Gravity:2.5-2.7
Solubility in Water:NOT SOLUBLE
Appearance and Odor:WHITE SHINY THREAD OR YARN; ODORLESS.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HYDROFLUORIC ACID, PHOSPHORIC ACID, STRONG ALKALIES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE MAY BE GENERATED BY
ORGANIC BINDER DURING INITIAL HEATING.
==================== Disposal Considerations ====================
Waste Disposal Methods:TO PVNT WASTE MATLS BECOMING AIRBORNE, COVERED
CNTNR/PLASTIC BAGGING IS REC. COMPLY W/FED, STATE & LOC REGS. METH
OF DISP:LANDFILL. CHEM ADDNS, PROCESSING/OTHERWISE ALTERING THIS
MATL MAY MAKE WASTE M ANAGEMENT INFO PRESENTED IN THIS MSDS (ING
11)
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:02Y024,CATALYST,POLYAMIDE,PART B
Kit Part:Y
Preparer's Name:N. GAUL
CAGE:HO407
CAGE:33461
CAGE:HO407
============= Composition/Information on Ingredients =============
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 5%
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:N-BUTYL ALCOHOL (SARA III)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 20%
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 30%
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 5%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 20%
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:POLYAMIDE RESIN
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:VAPORS ARE IRRITATING. CHRONIC:
CONTACT MAY CAUSE SKIN SENSITIZATION,ASTHMA,OTHER ALLERGIC
RESPONSES. PROLONGED/REPEATED EXPOSURE MAY CAUSE DELAYED EFFECTS
INVOLVING BLOOD,G/I,NERVOUS,REPRODUCTIVE SYS TEM.
Effects of Overexposure:EYE/SKIN:IRRITATION,BURNING,DRYING.
INHALED:RESPIRATORY IRRITATION,HEADACHE,DIZZINESS,UNCONSCIOUS.
INGESTED:G/I IRRITATION,NAUSEA & VOMITING. LATER MAY CAUSE
ASPIRATION OF SOLVENTS AND CHEMICAL PNEUMO NITIS.
Medical Cond Aggravated by Exposure:ALLERGIES,INCLUDING ASTHMA & SKIN
DISORDERS.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH WITH WATER. SKIN:WASH WITH SOAP & WATER. REMOVE
CONTAMINATED CLOTHING. INHALED:REMOVE FROM EXPOSURE. TREAT
BREATHING DIFFICULTY. GET MEDICAL ATTENTION. INGESTED:DO NOT INDUCE
VOMITING. NOTHI NG BY MOUTH IF UNCONSCIOUS. GET IMMEDIATE MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:23F/-5C
Lower Limits:1.2
Upper Limits:11.5
Extinguishing Media:FOAM,ALCOHOL FOAM,CARBON DIOXIDE,DRY CHEMICAL,WATER
FOG.
Fire Fighting Procedures:USE FULL FIRE FIGHTING EQUIPMENT WITH SCBA.
COOL FIRE EXPOSED CONTAINERS WITH WATER TO PREVENT EXPLOSION.
Unusual Fire/Explosion Hazard:FUMES/VAPORS RELEASED DURING EMERGENCY
CONDITIONS MAY BE A HEALTH HAZARD. SYMPTOMS MAY BE DELAYED.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. VENTILATE AREA.
CONTAIN & REMOVE WITH INERT ABSORBENT AND NON-SPARKING TOOLS.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE TIGHTLY CLOSED IN A
COOL,DRY,WELL VENTILATED,LOW FIRE RISK AREA. STORE AWAY FROM
IGNITION SOURCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH RESPIRATOR FOR ORGANIC VAPORS WHEN
WORKING IN ENCLOSED AREA OR EXPOSED ABOVE TLV OR PEL.
Ventilation:USE GENERAL VENTILATION OR LOCAL EXHAUST TO MAINTAIN
EXPOSURE BELOW TLV OR PEL.
Other Protective Equipment:LONG SLEEVE/LEG CLOTHING. LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.
Work Hygienic Practices:USE NORMAL CHEMICAL HYGIENE PRACTICE. SMOKE
ONLY IN DESIGNATED SMOKING AREAS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:175-259F
Vapor Density:>AIR
Spec Gravity:0.8
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:YELLOW VISCOUS LIQUID SOLVENT ODOR.
Percent Volatiles by Volume:84%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS,MINERAL ACIDS, UNCONTROLLED CONTACT WITH AMINES.
Stability Condition to Avoid:HEAT,IGNITIONS SOURCES.
Hazardous Decomposition Products:NORMAL PRODUCTS OF COMBUSTION, CHROME
OXIDES,ALDEHYDES,ACIDS.
Conditions to Avoid Polymerization:THOUGH LISTS "NO" TO HAZ.POLY:; MAY
REACT UNCONTROLLABLY WITH AMINES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W FEDERAL,STATE,LOCAL REGULATIONS.
HMIS SUGGESTS INCINERATION,OR LANDFILL. DO NOT INCINERATE CLOSED
CONTAINERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:METCO 461NS
CAGE:GO106
CAGE:GO106
CAGE:39918
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM (POWDER) *95-1*
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 5.5%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:COBALT (ANIMAL CARCINOGEN BY IARC - GROUP 2B) *95-1*
CAS:7440-48-4
RTECS #:GF8750000
Fraction by Wt: 2.5%
Other REC Limits:0.05 PPM
OSHA PEL:0.05 MG/CUM
ACGIH TLV:0.05 MG/CUM
Ingred Name:YTTRIA; YTTRIUM OXIDE
CAS:1314-36-9
RTECS #:ZG3850000
Fraction by Wt: 0.5%
OSHA PEL:1 MG/CUM
ACGIH TLV:1 MG/CUM
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: 1%
OSHA PEL:10 MG/CUM
ACGIH TLV:10 MG/CUM
Ingred Name:MANGANESE, MN COMPOUNDS
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 2%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM (DUST)
Ingred Name:CHROMIUM METAL, CHROMIUM, CHROME (KNOWN CARCINOGEN BY NTP;
IARC - GROUP 3) *95-1*
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 17.5%
OSHA PEL:1 MG/CUM
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:IRON *95-1*
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: 0.5%
OSHA PEL:10 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:NICKEL (SUSPECTED ANIMAL CARCINOGEN BY IARC GROUP
2B, SUSPECTED CARCINOGEN BY NTP) *95-1*
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 67%
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/CUM
ACGIH TLV:0.05 MG/CUM IC
Ingred Name:ORGANIC BINDER
Fraction by Wt: 3.5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: CONJUNCTIVAL IRRITATION. SKIN:
IRRITATION, DERMATITIS, ECZEMA, SENSITIZATION, CHROME LESIONS.
INHALATION: MUCOUS MEMBRANE IRRITATION/ULCERATION, IRRITATION OF
RESPIRATORY SYSTEM. INGESTION: IRRI TATION TO RESPIRATORY TRACT.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:IRRITATION, DISCOLORATION, COUGH, WHEEZING,
SHORTNESS OF BREATH, DECREASED CHEST EXPANSION, LESSENED CAPACITY
FOR WORK.
Medical Cond Aggravated by Exposure:N/K
.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15-20 MINS. SKIN: WASH W/SOAP &
WATER. INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE CLASS D FIRE EXTINGUISHER.
Fire Fighting Procedures:TREAT AS A METALLIC FIRE. WEAR A NIOSH/MSHA
APPROVED SELF CONTAINED BREATHING APPARATUS & FULL PROTECTIVE
CLOTHING.
Unusual Fire/Explosion Hazard:FINE METAL DUSTS ARE FLAMMABLE & MAY
EXPLODE WHEN EXPOSED TO HEAT, FLAME/OXIDIZERS.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM LOOSE POWDER ONLY W/VACUUMS EQUIPPED
W/HEPA FILTRATION. VACUUMS APPROPRIATE FOR USE W/METALLIC DUSTS
SHOULD BE UTILIZED. WIPE AREA CLEAN. DON'T USE WATER FOR CLEAN UP
OPERATIONS. DON'T SWEEP. A VOID GENERATING AIRBORNE DUST.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM INCOMPATIBLES, IN A
WELL VENTILATED/CLEAN/COOL & DRY AREA, IN A MANNER TO MINIMIZE
PUNCTURES & BREAKAGE OF CONTAINERS.
Other Precautions:AVOID INGESTION/INHALATION & EXCESSIVE SKIN CONTACT,
CONTACT OF POWDER W/WATER & OXIDIZERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH APPROVED RESPIRATOR W/FILTER
CARTRIDGE FOR DUST/FUMES/MISTS AT ALL TIMES DURING THERMAL SPRAY
PROCESS, WHEN PRODUCT HANDLING GENERATES DUST.
Ventilation:APPROPRIATE LOCAL EXHAUST.
Other Protective Equipment:EAR PROTECTION, ALUMINIZED APRON/OTHER
APPROPRIATE PROTECTIVE CLOTHING, WASH FACILITIES, EYE WASH STATION.
Supplemental Safety and Health
FOR COMBUSTION SPRAYING, SHADE # 9 FOR PLASMA SPRAYING UP TO 40 KW,
SHADE # 10 FOR PLASMA SPRAYING 40-60 KW, SHADE # 11 FOR PLASM A
SPRAYING >60 KW.
================== Physical/Chemical Properties ==================
Solubility in Water:INSOLUBLE
Appearance and Odor:POWDER W/NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NICKEL NITRATE, COMBUSTIBLES, OXIDIZERS, ACIDS, SULFUR.
Stability Condition to Avoid:HEAT, FLAME & OTHER IGNITION SOURCES.
Hazardous Decomposition Products:OZONE & NITRIC OXIDE, CO, CO2,
NITROGEN & SULFUR OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:EMPTY PRODUCT CONTAINERS, PRODUCT WASTE &
CLEANING MEDIA SHOULD BE DISPOSED OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: 51626A PRINT CARTRIDGES FOR DESKJET (PLAIN
Cage: 28480
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 28480
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50, ORAL, BLACK INK >2000 MG/KG
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: DYES IN INK MAKE EXPOSURE EASY TO DETECT. EYE CONTACT MAY
CAUSE IRRITATION. SKIN CONTACT MAY CAUSE IRRITATION. INGESTION MAY RESULT IN
GASTRIC DISTURBANCES. (NONE 0F THE INKS ARE TOXIC BY SKIN CONTACT ).
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYE: FLUSH WITH LARGE AMOUNTS OF WARM WATER FOR AT LEAST 15 MINUTES.
SKIN: WASH AFFECTED AREA WITH SOAP & WATER. INGESTION: DILUTE WITH WATER.
GET MEDICAL ATTENTION.. INHALATION: MOVE TO FRESH AIR.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: USE ABSORBENT TOWEL TO WIPE UP INK. RINSE AREA WITH
DAMP CLOTH TO REMOVE REMAINING TRACES OF INK.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL OF USED PRINT CARTRIDGES: DISPOSE OF IN
ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL LAWS.
Handling And Storage Precautions: AVOID CONTACT BETWEEN THE GOLD CARTRIDGE FACE
AND EYES, SKIN, AND CLOTHING.
Other Precautions: KEEP OUT OF REACH OF CHILDREN. RAPID REMOVAL OF INK WITH
SOAP AND WATER FROM SKIN PREVENTS IRRITATION AND STAINING.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: >255F,>124C
Extinguishing Media: WATER, DRY CHEMICAL, CARBON DIOXIDE, FOAM.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT
Unusual Fire/Explosion Hazard: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NO SPECIAL CONTROL MEASURES ARE REQUIRED
Ventilation: NO SPECIAL CONTROL MEASURES ARE REQUIRED
Other Protective Equipment: NO SPECIAL CONTROL MEASURES REQUIRED WHEN USING
PRINT CARTRIDGES.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: MANUFACTURER STATE IN MSDS THAT "PRINT
CARTRIDGES ARE EXEMPTED AS ARTICLES FROM THE OSHA COMMUNICATION STANDARD".
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
B.P. Text: >230F,>110C
Vapor Pres: 15 @ 20C
Vapor Density: 3
Spec Gravity: 1.1
Solubility in Water: COMPLETE
Appearance and Odor: BLACK LIQUID, PRACTICALLY ODORLESS
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NONE.
Hazardous Decomposition Products: NONE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 9164
Product ID: 51626A PRINT CARTRIDGES FOR DESKJET (PLAIN
Review Date: 06/09/1994
Multiple KIT Number: 0
Review IND: Y
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: 51626A PRINT CARTRIDGES FOR DESKJET (PLAIN
Cage: 28480
Company Name: HEWLETT-PACKARD CO, CORPORATE HQ
Street: 3000 MINUTEMAN RD
Zipcode: 01810-1032
Label Required IND: Y
Date Of Label Review: 06/09/1994
Status Code: C
MFG Label NO: NONE
Label Date: 06/09/1994
Origination Code: F
Signal Word: CAUTION
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: DYES IN INK MAKE EXPOSURE EASY TO DETECT. EYE CONTACT
MAY CAUSE IRRITATION. SKIN CONTACT MAY CAUSE IRRITATION. INGESTION MAY RESULT
IN GASTRIC DISTURBANCES. (NONE 0F THE INKS ARE TOXIC BY SKIN CONTACT ). AVOID
CONTACT BETWEEN THE GOLD CARTRIDGE FACE AND EYES, SKIN, AND CLOTHING. FIRST
AID: EYE: FLUSH WITH LARGE AMOUNTS OF WARM WATER FOR AT LEAST 15 MINUTES.
SKIN: WASH AFFECTED AREA WITH SOAP & WATE R. INGESTION: DILUTE WITH
WATER. GET MEDICAL ATTENTION.. INHALATION: MOVE TO FRESH AIR. TARGET ORGAN:
SKIN.
=======================================================
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:KAOWOOL ROPE
CAGE:0UHC8
CAGE:0UHC8
============= Composition/Information on Ingredients =============
Ingred Name:FIBERS, REFRACTORY CERAMIC; (REFRACTORY CERAMIC FIBER) (AS
MANUFACTURED)
CAS:142844-00-6
RTECS #:LK3628000
Fraction by Wt: >80%
OSHA PEL:1 FIBER/CC (MFR)
ACGIH TLV:1 FIBER/CC (MFR)
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE (PRODUCED AFTER NORMAL
USE)
CAS:14464-46-1
RTECS #:VV7325000
OSHA PEL:0.05 MG/M3 (MFR)
ACGIH TLV:0.05 MG/M3 RDUST
Ingred Name:SUPDAT:SHOULD (1)MONITOR FOR AIRBORNE FIBERS & RESPIRABLE
CRISTOBALITE CONCS USING NIOSH METH 7400(B) & 7500 (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:RESPECTIVELY & SELECT APPROP RESP PROT BASED UPON
RSLTS OF THAT MONITORING, (2)HAVE WORKERS EVALUATED BY MD(ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:TO DETERMINE WORKER'S ABILITY TO WEAR RESPS, &
(3)IMPLEMENT RESP PROT TRAINING PROGRAMS. USE NIOSH/MSHA (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:APPRVD RESPS, IN COMPLIANCE W/OSHA RESP PROT STD 29
CFR 1910.134 & 29 CFR 1926.103, FOR PARTICULAR HAZ/ (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:AIRBORNE CONCS TO BE ENCOUNTERED IN WORK ENVIRON. MIN
ACCEPT NIOSH/MSHA APPRVD RESP TYPE WHEN HNDLG RCF (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:PRODS: AS-PRDCD/"VIRGIN" FIBERS: TO 1
FIBER/CC:DISPOSABLE DUST/MIST RESP (E.G. 3M 9900); TO 5 FIBERS/CC:
(ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:HALF-FACE, AIR-PURIFYING RESP EQUIPPED W/HIGH
EFFICIENCY PARTICULATE AIR(HEPA) FILTER CARTRIDGES (E.G. 3M (ING
10)
RTECS #:9999999ZZ
Ingred Name:ING 9:6000 SERIES); TO 25 FIBERS/CC:FULL-FACE AIR-PURIFYING
RESP W/HIGH EFFICIENCY PARTICULATE AIR(HEPA) FILTER (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:CARTRIDGES (E.G. 3M 7899 W/7255 FILTERS)/POWERED
AIR-PURIFYING RESP(PAPR) EQUIPPED W/HEPA FILTER (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:CARTRIDGES (E.G. 3M W3265S W/W3267 FILTERS); >25
FIBERS/CC:FULL-FACE POS PRESS SUPPLIED AIR RESP (E.G. 3M(ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:7800 W/W9435 HOSE & W3196 REGULATOR). AFTER-SERVICE
FIBERS/CRISTOBALITE: UP TO 5 FIBERS/CC OR UP TO 0.05 (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:MG/M3 RESPIRABLE CRISTOBALITE - HALF-FACE,
AIR-PURIFYING RESP W/HIGH-EFFICIENCY PARTICULATE AIR (HEPA) (ING
15)
RTECS #:9999999ZZ
Ingred Name:ING 14:FILTER CARTRIDGES (E.G. 3M 6000 SERIES); 5-25
FIBERS/CC OR 0.5-2.5 MG/M3 RESPIRABLE CRISTOBALITE - FULL- (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:FACE AIR-PURIFYING RESP EQUIPPED W/HIGH-EFFICIENCY
PARTICULATE AIR (HEPA) FILTER CARTRIDGES (E.G. 3M7800 (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:W/7255 FILTERS) OR POWERED AIR-PURIFYING RESP (PAPR)
EQUIPPED W/HEPA FILTER CARTRIDGES (E.G. 3M W3265S (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:W/W3267 FILTERS); >25 FIBERS/CC OR >2.5 MG/M3
RESPIRABLE CRISTOBALITE - FULL-FACE POS PRESS SUPPLIED AIR (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:RESP (E.G. 3M7800 W/W9435 HOSE & W3196 REGULATOR).
RTECS #:9999999ZZ
Ingred Name:HYGIENE PRACT:BEFORE REMOVING FROM WORK AREA.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EXPOS TO DUST SHOULD BE MINIMIZED.
INHAL IS NOT EXPECTED TO CAUSE ANY LONG-TERM HLTH PROBLEMS. PRLNG
SKIN/EYE CONTACT MAY CAUSE TEMPORARY MECH IRRIT IN SOME
INDIVIDUALS. LONG-TERM EXPOS TO RCF CAUSESNO KNOWN CHRONIC HLTH
PROBS IN HUMANS. AS MFRD, THESE PRODS ARE ALUMINOSILICATES WHICH
MAY TRANSFORM (EFTS OF OVEREXP)
Explanation of Carcinogenicity:FIBROUS GLASS:IARC SCIENTIFIC PUBS, VOL
8, PG 289, 1973:GRP 2B. ANIMAL:EYE, SKIN, RESP SYS. SILICA,
CRYSTALLINE-(SUPDAT)
Effects of Overexposure:HLTH HAZ:UPON HEATING TO MULLITE & CRISTOBALITE
(FORM OF CRYSTALLINE SILICA). REMOVAL OF RCF PRODS AFTER SERVICE
MAY GENERATE DUST. PRLNG/RPTD INHAL OF RESPIRABLE FREE CRYSTALLINE
SILICA DUST MAY CAUS E DELAYED LUNG INJURY (SILICOSIS).
Medical Cond Aggravated by Exposure:HANDLING RCF PRODUCTS MAY GENERATE
RESPIRABLE PARTICULATES WHICH MAY CAUSE TEMPORARY IRRITATION OR
DISCOMFORT OF THE SKIN, EYES, NOSE, THROAT OR LUNGS & MAY AGGRAVATE
BRONCHIAL DISORDERS.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. INGEST:DRINK PLENTY OF WATER.
SKIN:WASH W/MILD SOAP & WATER. EYES:FLUSH W/PLENTY OF WATER FOR AT
LEAST 15 MINUTES. IF IRRITATION PERSISTS, CALL MD.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
================== Accidental Release Measures ==================
Spill Release Procedures:FOLLOW ROUTINE HOUSEKEEPING PROCEDURES.
VACUUMING W/HEPA FILTER IS PREFERRED; IF SWEEPING IS NECESSARY, USE
A DUST SUPPRESSANT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE W/ADEQUATE VENTILATION. EXPOSURE
TO DUST SHOULD BE MINIMIZED.
Other Precautions:APPROPRIATE VENTILATION & RESPIRATORY PROTECTION
SHOULD BE PROVIDED IN COMPLIANCE W/OSHA STANDARDS 29 CFR 1910.94 &
1910.134, RESPECTIVELY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN IT IS NOT POSS/FEASIBLE TO ELIM AIRBORNE
FIBER &/OR CRISTOBALITE DUST LEVELS BELOW PEL/REG THRU ENGINEERING
CONTROLS/UNTIL THEY ARE INSTALLED, EMPLOYEES ARE ENCOURAGED TO USE
GOOD WORK PRACTICES TOGETHER W/RESP PROT. BEFORE (SUPP DATA)
Ventilation:USE ENGINEERING CTLS SUCH AS VENT & DUST COLLECTION DEVICES
TO REDUCE AIRBORNE FIBER CONCS TO LOWEST ATTAINABLE LEVEL.
Other Protective Equipment:LONG SLEEVED SHIRTS & PANTS ARE RECOMMENDED.
Work Hygienic Practices:WASH EXPOS CLTHG SEPARATELY FROM OTHER CLTHG &
RINSE WASHER THORO. VACUUM WORK CLTHG W/HEPA FILTERED VACUUM (ING
20)
Supplemental Safety and Health
HAZ DECOMP PROD:HYDROGEN CYANIDE & ACRYLONITRILE) IN SM QTY NOT
BELIEVED TO BE HARMFUL. EXPLAN OF CARCIN:CRISTOBALITE:IARC
MONOGRAPHS, SUPP, VOL 7, PG 341, 1987:GRP 2A. NTP 6TH ANNUAL RPT ON
CARCINS, 1991:ANTIC TO BE CARCIN. RESP PROT:PROVIDING NIOSH/MSHA
APPRVD RESPS TO EMPLOYEES (ESP NEG PRESS TYPE), EMPLOYERS(ING 3)
================== Physical/Chemical Properties ==================
Spec Gravity:2.5 (H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE, NON-WOVEN MAT; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONCENTRATED MINERAL ACIDS OR BASES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:AT HIGH TEMPS, SURF TREATMENT ON
FIBERS WILL DECOMPOSE, POSS RELS DECOMP PRODS (CARBON MONOXIDE,
ETHYLENEIMINE, (SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTES ARE NOT HAZARDOUS WASTES AS DEFINED BY
RCRA (40 CFR 261). COMPLY W/FEDERAL, STATE & LOCAL REGULATIONS.
METHOD OF DISPOSAL: LANDFILL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ZPG-1035
Preparer's Name:GORDON POLIQUIN
CAGE:4W458
CAGE:4W458
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 30-60%
Other REC Limits:525 MG/CUM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED (C10-C15 SATURATED
HYDROCARBONS 97%, C10 AROMATICS 3%) *96-2*
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 15-40%
Other REC Limits:200 PPM EXXON
Ingred Name:VOLATILE ORGANIC CONTENT: 4.47 LBS/GAL (LESS WATER; 536
GM/L
RTECS #:9999999VO
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): >5 GM/KG (SEE SUPP)
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION, DERMATITIS. EYES:
IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:DEPRESSION, LOSS OF CONSCIOUSNESS, CONVULSIONS,
BURNING, IRRITATION, DEFATTING.
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/WATER FOR 15 MINS.
INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN IF NEEDED. INGESTION:
DON'T INDUCE VOMITING. GIVE WHITE MINERAL OIL. DON'T ATTEMPT TO
GIVE ANYT HING BY MOUTH TO AN UNCONSCIOUS PERSON.OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:101F
Lower Limits:0.8
Upper Limits:6
Extinguishing Media:FOAM, DRY CHEMICAL, WATER FOG, CO2
Fire Fighting Procedures:USE SCBA. REMOVE IGNITION SOURCES. COOL
CONTAINERS W/WATER SPRAY.
Unusual Fire/Explosion Hazard:AUTOIGNITION TEMP: >410F. VAPORS ARE >AIR
& MAY FLOW TO DISTANT IGNITION SOURCES.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES. PROVIDE ADEQUATE
VENTILATION. ABSORB W/VERMICULITE/OTHER ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, WELL VENTILATED AREA
AWAY FROM IGNITION SOURCES.
Other Precautions:AVOID SKIN CONTACT & BREATHING OF VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE AIR PURIFYING RESPIRATOR W/ORGANIC VAPOR
CARTRIDGE >TLV IF LIMITS ARE EXCEEDED.
Ventilation:EXPLOSION PROOF LOCAL EXHAUST. MAINTAIN ADEQUATE AIR
TRANSFER VELOCITY TO REMOVE VAPORS.
Other Protective Equipment:BUNA-N-RUBBER APRON, EYE WASH, SAFETY
SHOWER.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY BEFORE EATING, DRINKING/SMOKING.
Supplemental Safety and Health
ORAL LD50 INFORMATION IS FOR ALIPHATIC HYDROCARBONS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>300F
Vapor Pres:<10
Vapor Density:5
Spec Gravity:0.87
pH:7
Evaporation Rate & Reference:(ETHER =1): 36
Solubility in Water:NONE
Appearance and Odor:LIGHT COLORED LIQUID W/MILD ODOR
Percent Volatiles by Volume:67.7
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS & ACIDS.
Stability Condition to Avoid:IGNITION SOURCES.
Hazardous Decomposition Products:OXIDES OF CARBON, NITROGEN, SULFUR &
CALCIUM.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. FLAMMABLE LIQUID, UN1268.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:VIDEO DISPLAY CLEANER (550087-18)
CAGE:PERFE
CAGE:PERFE
CAGE:60902
CAGE:49269
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ALCOHOL (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 10%
Other REC Limits:NONE DETERMINED
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9192
Ingred Name:2-BUTOXYETHANOL
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 75%
Other REC Limits:NONE DETERMINED
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: ORAL(RAT) IS 470 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONCENTRATE IS AN EYE IRRITANT & IS
HARMFUL IF SWALLOWED. PROLONG SKIN CONTCT MAY BE HARMFUL. PROLONGED
& EXTENSIVE SKIN CONTACT MAY LEAD TO SYMPTOMS SIMILIAR TO
INGESTION. INGESTION OF CONCENTRATE MA Y CAUSE HEMOLYSIS LEADING TO
POSSIBLE LIVER & KIDNEY DAMAGE DUE TO 2-BUTOXYETHANOL.
Explanation of Carcinogenicity:NOT CARCINOGENIC.
Effects of Overexposure:EYE CONTACT-REDNESS, SWELLING, SENSATION OF
IRRITATION. SKIN CONTACT-REPEATED SKIN EXPOSURE MAY CAUSE
IRRITATION. INGESTION-SYMPTOMS INCLUDED HEADACHE, DIZZINESS,
INCOORDINATION, NAUSEA, VOMITING, DIA RRHEA AND GENERAL WEAKNESS.
INHALATION-FOR SIGNS AND SYMTOMS SEE INGESTION.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:EYE: (IF CONTACTS WORN, REMOVE) FOR 15 MINUTES FLUSH EYES
WITH WATER. IF IRRITATION PERSISTS, CONTACT PHYSICIAN. SKIN: WASH
WITH SOAP & WATER AFTER CONTACT. IF INGESTED: DRINK A GLASS OF
WATER, THEN I MMEDIATELY CONTACT A POISON CONTROL CENTER OR A
PHYSICIAN TO SEE WHEN TO INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:113F,45C
Extinguishing Media:IN CASE OF FIRE, USE WATER, DRY ALCOHOL-TYPE OR ALL
PURPOSE FOAM, DRY CHEM CO2 OR OTHER CLASS B EXTINGUISHING AGENTS.
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT, INCLUDING PRESSURE
DEMAND SELF-CONTAINED BREATHING APPARATUS & TURNOUT EQUIPMENT
SHOULD BE WRON BY FIREFIGHTERS & OTHER EXPOSED.
Unusual Fire/Explosion Hazard:COMBUSTIBLE. KEEP AWAY FROM HEAT AND
FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE POSSIBLE SOURCES OF IGNITION. AVOID
CONT W/EYES, SKIN, MOUTH & CLOTHING. WEAR PROTECTIVE EYEWEAR &
ABSORBENT MOP. FOLLOW BY MOPPING OR FLUSHING AREA WITH CLEAN
WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL-VENTILATED
AREA. STORE AWAY FORM SPARKS, OPEN FLAME OR ANY SOURCE OF HEAT.
AVOID EYE CONTACT AND PROLONGED SKIN CONTACT.
Other Precautions:ALWAYS PRACTICE GOOD HOUSEKEEPING AND HYGIENE
MEASURES. CLEAN UP SPILLS IMMEDIATELY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY NEEDED.
Ventilation:NOT NORMALLY NEEDED.
Other Protective Equipment:NOT NORMALLY NEEDED.
Supplemental Safety and Health
THIS IS PART "B" OF A THREE PART KIT.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:152F,67C
Spec Gravity:0.910
pH:7-8
Evaporation Rate & Reference:<1 (BUAC=1)
Solubility in Water:100
Appearance and Odor:DEEP BLUE-COLORED CLEAR LIQUID WITH AN ALCOHOL
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE ONLY IN ACCORDANE WITH APPLICABLE
FEDERAL, STATE, AND LOCAL LAWS AND REGULATIONS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:2-BROMO-2-METHYLPROPANE, O-614
CAGE:84898
CAGE:84898
CAGE:8Y898
============= Composition/Information on Ingredients =============
Ingred Name:PROPANE, 2-BROMO-2-METHYL-; (2-BROMO-2-METHYLPROPANE)
CAS:507-19-7
RTECS #:TX4150000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT LENSES SHOULD NOT BE WORN IN
LAB. ALL CHEMICALS SHOULD BE CONSIDERED HAZ - AVOID DIRECT PHYSICAL
CONTACT. CAN CAUSE EYE IRRIT. CAN BE HARMFUL IF SWALLOWED. CAN BE
IRRIT TO MUCOUS MEMBRANES. CA N BE HARMFUL IF ABSORBED THRU SKIN.
CANBE HARMFUL IF INHALED. LACHRYMATOR - CAUSES SEVERE EYE IRRIT.
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:CAN CAUSE SKIN IRRITATION. SUSPECTED
CARCINOGEN - MAY PRODUCE CANCER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:AN ANTIDOTE IS A SUBSTANCE INTENDED TO COUNTERACT EFT OF
POIS. IT SHOULD BE ADMIN ONLY BY MD/TRAINED EMER PERS. MED ADVICE
CAN BE OBTAINED FROM POIS CTRL CTR. EYE: FLUSH CONTINUOUSLY W/WATER
FOR AT LE AST 15-20 MINS. FLUSH SKIN W/WATER FOR 15-20 MINS. IF NO
BURNS HAVE OCCURRED-USE SOAP & WATER TO CLEANSE SKIN. INHAL: REMOVE
PATIENT TO FRESH AIR. ADMIN O*2 IF PATIENT IS HAVING DFCLTY
BRTHG.(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:64.4F,18.0C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER OR WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:EVAC AREA. WEAR APPROP OSHA/NIOSH/MSHA APPRVD
EQUIP. VENT AREA. ABSORB ON VERMICULITE OR SIMILAR MATL. SWEEP UP &
PLACE IN AN APPROP CNTNR. HOLD FOR DISP. WASH CONTAMD SURFACES TO
REMOVE ANY RESIDUES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP TIGHTLY CLSD & STORE IN COOL DRY
PLACE. STORE ONLY W/COMPATIBLE CHEMICALS. AVOID CONTACT W/SKIN,
EYES & CLTHG.
Other Precautions:THIS PRODUCT IS FURNISHED FOR LAB USE ONLY! PRODUCTS
MAY NOT BE USED AS DRUGS, COSMETICS, AGRICULTURAL OR PESTICIDAL
PRODUCTS, FOOD ADDITIVES OR AS HOUSEHOLD CHEMICALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:THIS CHEMICAL SHOULD BE HANDLED ONLY IN HOOD.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: IF PATIENT HAS STOPPED BRTHG ADMIN ARTF RESP. IF
PATIENT IS IN CARD ARREST ADMIN CPR. CONTINUE LIFE SUPPORTING
MEASURES UNTIL MED ASSIST HAS ARRIVED.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:165F,74C
Melt/Freeze Pt:M.P/F.P Text:-4F,-20C
Spec Gravity:1.189
Solubility in Water:IMMISCIBLE
Appearance and Odor:YELLOW LIQUID W/ETHER LIKE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES, STRONG OXIDIZING AGENTS. DO NOT USE MAGNESIUM/ALUMINUM OR
THEIR ALLOYS AS CONTAINERS.
Stability Condition to Avoid:LOW REACTIVITY. FLAMMABLE.
Hazardous Decomposition Products:DECOMPOSITION LIBERATES TOXIC FUMES.
DECOMPOSITION PRODUCTS ARE CORROSIVE.
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN CHEMICAL INCINERATOR EQUIPPED W/AN AFTER
BURNER & SCRUBBER. DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MERCURY IN GLASS THERMOMETER
Preparer's Name:ANDREW ZOREMCHAK
CAGE:55560
CAGE:55560
============= Composition/Information on Ingredients =============
Ingred Name:MERCURY (SARA III)
CAS:7439-97-6
RTECS #:OV4550000
Fraction by Wt: 100%
Other REC Limits:NONE
OSHA PEL:S, C, 0.1 MG/M3
ACGIH TLV:S, 0.05 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES & MUCOUS MEMBRANE IRRITANT;CAN
PENETRATE UNDAMAGED SKIN WITH SUBSEQUENT ABSORPTION.ALSO DERMATITIS
& ALLERGIES;INGESTION CAN BE DANGEROUS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SEVERE RESPIRATORY IRRITATION,CHEST
PAINS,BREATHING DIFFICULTY & COUGHING.THESE SYMPTOMS MAY ALSO BE
ACCOMPANIED BY SOME OR ALL SYMPTOMS OF CHRONIC POISONING.GUM &
MOUTH INFLAMMATION (ACCOMPANIED BY E XCESS SALIVATION & METALLIC
TASTE),IRRITABILITY,TREMORS.
Medical Cond Aggravated by Exposure:PERSONS WITH CHRONIC DISEASES LIKE
TUBERCULOSIS,KIDNEY DISEASE & ALCOHOLISM OR ARE IN POOR PHYSICAL
CONDITION SHOULD AVOID MERCURY. KIDNEY ACCUMULATES MERCURY. DAMAGE
IS CAUSED BY ACUTE POISONING.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH PLENTY OF WATER;SKIN:WASH WITH SOAP &
WATER;INHALATION:REMOVE TO FRESH AIR.GIVE OXYGEN/CPR IF
NEEDED;INGESTION:SEE DOCTOR IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:USE SCBA OR AIR LINE RESPIRATORS ONLY.
Unusual Fire/Explosion Hazard:WILL FORM TOXIC FUMES WHEN HEATED.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP SPILLS IMMEDIATELY WITH VACUUM
EQUIPMENT WITH FILTERED EXHAUST.DO NOT DRY SWEEP.AVOID SKIN CONTACT
WITH MERCURY.WASH CONTACTED AREA WITH SOAP & WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE & STORE THERMOMETER WITH PROPER
CARE.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATORY PROTECTION ONLY REQUIRED IN CASE OF
SPILLAGE.
Ventilation:VENTILATE IN CASE OF SPILLAGE.
Other Protective Equipment:PROTECTIVE CLOTHING IN CASE OF SPILLAGE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING SPILLAGE.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:Z2
Boiling Pt:=357.8C, 676.F
Melt/Freeze Pt:=-38.7C, -38.F
Vapor Pres:NEGLIGIBLE
Vapor Density:1.015
Spec Gravity:13.59
Evaporation Rate & Reference:<1
Solubility in Water:INSOLUBLE
Appearance and Odor:SILVERY,MOBILE,ODORLESS LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACETYLENES,AMMONIA GASES
Stability Condition to Avoid:HEAT
Hazardous Decomposition Products:MERCURY FUMES,MERCURY COMPOUNDS
==================== Disposal Considerations ====================
Waste Disposal Methods:REMOVE TO PROPER DISPOSAL AREA I/A/W
FEDERAL,STATE & LOCAL REGULATIONS. DO NOT PUT IN GARBAGE,FLUSH IN
SEWER OR INCINERATE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HYDRAZINE STD
CAGE:61084
CAGE:61084
============= Composition/Information on Ingredients =============
Ingred Name:HYDROGEN CHLORIDE; (HYDROCHLORIC ACID) (SARA III)
CAS:7647-01-0
RTECS #:MW4025000
Fraction by Wt: 22%
OSHA PEL:5 PPM, C
ACGIH TLV:5 PPM, C
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:HYDRAZINE DIHYDROCHLORIDE
CAS:5341-61-7
RTECS #:MV2298000
Fraction by Wt: 0.8%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT MAY CAUSE PERMANENT DAMAGE TO
EYES, SEVERE BURNS, AND ULCERATIONS ON SKIN. INHALATION OF VAPORS
MAY DAMAGE RESPIRATORY TRACT. TOXIC BY INGESTION, INHALATION AND
ABSORPTION THROUGH SKIN.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES; GET IMMEDIATE
MEDICAL ASSISTANCE. SKIN: REMOVE CONTAMINATED CLOTHING AND WASH
WITH SOAP AND WATER. INHALATION: MOVE TO FRESH AIR AND GIVE
ARTIFICIAL RES PIRATION IF BREATHING HAS STOPPED. INGESTION: DO NOT
INDUCE VOMITING. GIVE MILK OR WATER IF CONSCIOUS. GET IMMEDIATE
MEDICAL ATTENTION. GET MEDICAL ASSISTANCE FOR ALL CASES OF
OVEREXPOSURE!
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:DRY CHEMICAL, FOAM, WATER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:REACTS WITH MOST METALS TO FORM HYDROGEN
GAS WHICH CAN FORM EXPLOSIVE MIXTURES WITH AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH SAND OR VERMICULITE AND SCOOP UP
AND CONTAINERIZE FOR PROPER DISPOSAL.
Neutralizing Agent:NEUTRALIZE WITH SODA ASH.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNR TIGHTLY CLSD. STORE IN
COOL, DRY, WELL VENTILATED AREA. KEEP AWAY FROM IGNIT SOURCE. EMPTY
CONTAINERS MAY BE HAZ DUE TO RETAINED RESIDUE.
Other Precautions:WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED SELF CONTAINED
BREATHING APPARATUS IN HIGH VAPOR AREAS.
Ventilation:PROVIDE ADEQUATE GENERAL AND LOCAL EXHAUST VENTILATION.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER .
Work Hygienic Practices:DO NOT GET IN EYES, ON SKIN OR CLOTHING. DO NOT
BREATHE VAPORS OR MIST.
Supplemental Safety and Health
EYE PROT: FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
HCC:C3
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID WITH ACRID ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BASES, OXIDIZERS, AND METAL POWDERS.
Stability Condition to Avoid:HEAT.
Hazardous Decomposition Products:HCL AND NO*X.
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY WITH ALL LOCAL, STATE AND FEDERAL
REGULATIONS.
======================================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:XR IONOMER LIQUID
Kit Part:Y
CAGE:GO270
CAGE:GO270
CAGE:33339
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS FOR INGREDIENTS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY BE HARMFUL BY
INHALATION. EYES: IRRITATION. SKIN: IRRITATION. INGESTION: CONSULT
A PHYSICIAN IF APPRECIABLE INGESTION OCCURED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INGESTION: POSSIBLE VOMITING.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MINS. SKIN: WASH W/SOAP &
WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION: CONSULT
PHYSICIAN. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL, CO2, WATER SPRAY
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP W/CLOTH & TRANSFER TO SUITABLE
CONTAINER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T REFRIGERATE THE LIQUID. IF
FROZEN, PRECIPITATION WILL OCCUR WHICH CANNOT BE REDISSOLVED. AFTER
DISPENSING, IMMEDIATELY RECAP.
Other Precautions:USE ACCORDING TO DIRECTIONS.
============= Exposure Controls/Personal Protection =============
Ventilation:USE IN A WELL VENTILATED AREA.
Work Hygienic Practices:HANDLE IN ACCORDANCE W/GOOD PERSONAL HYGIENE &
SAFETY PRACTICES. THESE PRACTICES INCLUDE AVOIDING UNNECESSARY
EXPOSURE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:100C
Spec Gravity:>1.0
Evaporation Rate & Reference:1.0
Solubility in Water:APPRECIABLE
Appearance and Odor:A CLEARM AMBER LIQUID W/A SLIGHT ACID ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALIES
Stability Condition to Avoid:DON'T REFRIGERATE THE XR IONOMER LIQUID.
IF FROZEN, PRECIPITATION WILL OCCUR WHICH CANNOT BE REDISSOLVED.
==================== Disposal Considerations ====================
Waste Disposal Methods:MATERIAL SHOULD NOT BE ALLOWED TO DRAIN TO
SEWERS. INCINERATE LIQUID IN PROPER EQUIPMENT. DISPOSE OF IN
ACCORDANCE W/LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MXB 7502 EXPOXY/GLASS PREPREG
Preparer's Name:BRAD DIERINGER
CAGE:GO063
CAGE:GO063
CAGE:07314
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE. %: TOTAL VOLATILES TYPICALLY <2%.
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: SEE ING
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:FIBROUS GLASS; (GLASS FIBER)
CAS:65997-17-3
Fraction by Wt: 55-75%
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (DUST)
Ingred Name:EPOXY RESINS
Fraction by Wt: 25-45%
Ingred Name:AMINE CATALYST
Fraction by Wt: 2%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EPOXY RESINS CAUSE IRRITATION OF SKIN
& EYES, AND POSSIBLE DERMATITIS OR ALLERGY/SENSITIZATION. VAPORS
COMING OFF HEATED MATERIAL MAY CAUSE IRRITATION. LIVER & KIDNEYS
MAY BE TARGET ORGANS IF SOME EPO XIES ARE INGESTED. EXISTING
ALLERGIES MAY BE AGGRAVATED. EPOXIES ARE COMMONLY MUTAGENIC TO
BACTERIA. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: EXCESSIVE INHALATION OF ACETONE
VAPORS CAN CAUSE NASAL AND RESPIRATORY IRRITATION, HEADACHE, CNS
DEPRESSION AND NARCOSIS. FIBERS CAUSE MECHANICAL SKIN IRRITATION &
POSSIBLE RESPIRATORY IRRIT ATION.
Medical Cond Aggravated by Exposure:EXISTING ALLERGIES MAY BE
AGGRAVATED.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR A MINIMUM OF 15 MINUTES, CONSULT MD.
SKIN: WASH W/SOAP & WATER. COOL WATER RINSING HELPS REMOVE FIBERS.
INHAL: MOVE TO FRESH AIR. INGEST: UNLIKELY TO BE A PROBLEM. CALL MD
IMME DIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA/FULL PROT EQUIP .
EXOTHERM FIGHT PROC: DISSIPATE HEAT BY SPREADING MATL APART &
DOUSING W/H*2O. CNTN EMISSIONS USING LOC EXHST.
Unusual Fire/Explosion Hazard:EXOTHERMIC POLYMERIZATION MAY OCCUR.
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP AND USE UNCONTAMINATED MATERIAL.
CONTAMINATED MATERIAL SHOULD BE PICKED UP AND DISPOSED OF PROPERLY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT 60-70F. IN ACCORDANCE W/GOOD
INDUSTRIAL PRACTICE, HANDLE WITH CARE AND AVOID UNNECESSARY
PERSONAL CONTACT.
Other Precautions:NUISANCE MATERIALS MAY BE RELEASED AS DUSTS WHEN
MACHINING CURED PRODUCTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USUALLY NOT NEEDED. USE NIOSH/MSHA APPROVED
RESPIRATORS, IF NECESSARY, TO CONTROL NUISANCE DUST EXPOSURE WHEN
MACHINING.
Ventilation:GOOD GENERAL VENTILATION & LOCAL EXHAUST RECOMMENDED,
PARTICULARLY WHERE GRINDING OR HEATING OPERATIONS OCCUR.
Other Protective Equipment:CLEAN BODY-COVERING CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.5-2.2
Appearance and Odor:IMPREGNATED FIBERS/NO ODOR.
Percent Volatiles by Volume:<2(WT)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HF, STRONG OXIDIZERS, STRONG ACIDS, STRONG BASES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CO*X, NO*X, AMINES, PHENOLS, BF*3.
Conditions to Avoid Polymerization:EXOTHERMIC POLYMERIZATION CAN OCCUR
W/RAPID OR EXCESSIVE HEAT. WHEN HEATED TO DECOMP, TOXIC EMISSIONS
MAY BE RELEASED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE, & FEDERAL
REGULATIONS, WHICH MAY VARY BY LOCATION. QUESTIONS CONCERNING
DISPOSAL SHOULD BE DIRECTED TO FIBERITE'S SAFETY, HEALTH, &
ENVIRONMENTAL AFFAIRS DEPT FOR EVALUA TION ON A CASE BY CASE BASIS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:W2599 REGENCY EXT 100% ACRYLIC WOOD & MASONRY PRIMER
CAGE:FO133
CAGE:97903
CAGE:FO133
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 45%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACRYLIC RESIN
CAS:29354-73-2
Fraction by Wt: 20%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM OXIDE;(TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 15%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:1,2-PROPANEDIOL; (PROPYLENE GLYCOL)
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PROPIONIC ACID,2-METHYL-,MONOESTER
W/2,2,4-TRIMETHYL-1,3-PENTANEDIOL; (2,2,4 TRIMETHYLPENTANE-DIOL-1,3
MONOISO-BUTYRATE)
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ZINC OXIDE (SARA 313) (CERCLA)
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: <5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:BICYCLIC OXAZOLIDINES SOLUTION (HEMIACETALS);(NUOSEPT95)
CAS:56709-13-8
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC CONTENT: 114 G/L (WATER).
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPP DATA: USED IN CONFINED AREAS, WEAR NIOSH/MSHA APPRVD
AIR SUPPLY RESPS/HOODS. USE NIOSH/MSHA APPRVD RESP (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: WHEN FLAME CUTTING, WELDING, BRAZING & SANDING MATL
COTAED W/PRODUCT. FOLLOW RESP MFR'S DIRECTIONS FOR RESP USE.
RTECS #:9999999ZZ
Ingred Name:VENT: CURRENT APPLICABLE SAFETY & HEALTH STANDARDS IN
MIXING, APPLICATION & CURING AREAS & TO REMOVE SANDING (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: DUSTS OR DRIED COATING & DECOMPOSITION PRODUCT
DURING WELDING & FLAME CUTTING ON SURFACES COATED W/PRODUCT.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: IRRIT OF RESP TRACT;
HEADACHE, NAUSEA, DIZZINESS. EYE/SKIN: MAY CAUSE EYE & SKIN IRRIT.
INGEST: LARGER QTYS MAY CAUSE DISTRESS OF THE DIGESTIVE TRACT &
NAUSEA. CHRONIC: PRLNGD/RPTD BREAT HING OF SPRAY MIST &/SANDING
DUST OVER A PERIOD OF YEARS MAY CAUSE DUST DISEASE OF THE LUNGS.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE WHEN USED IN ACCORDANCE WITH
SAFE HANDLING & USE NFORMATION.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. EYES: FLUSH W/LGE AMOUNTS OF
WATER FOR AT LEAST 15 MINS. GET MED ASSIST. SKIN: REMOVE W/SOAP &
WATER. REMOVE SOILED CLOTHING. INGEST: DRINK 1 OR 2 GLASSES OF
WATER TO DILUT E. DO NOT INDUCE VOMITING. CONSULT MD IMMED. TREAT
SYMPTOMATICALLY. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:NONE
Extinguishing Media:USE CO*2, DRY CHEMICAL, FOAM/OTHER NFPA APPROVED
METHOD FOR TREATING A CLASS B FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
SUMMON PROFESSIONAL FIREFIGHTERS. WATER SPRAY MAY BE INEFFECTIVE.
IF WATER IS USED, FOG NOZZ PREF.(SUPDAT)
Unusual Fire/Explosion Hazard:DUE TO PRESSURE BUILD-UP, CLSD CNTNRS
EXPOSED TO EXTREME HEAT MAY EXPLODE. AFTER WATER EVAPS, REMAINING
MATL WILL BURN. DURING EMER CNDTNS, OVEREXP (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:WASH W/WATER. BEFORE ATTEMPTING CLEAN-UP,
REFER TO HAZ CAUTION INFORMATION IN MSDS. CONTAIN SPILLED MATL &
REMOVE W/INERT ABSORB. STORE IN CLSD CNTNR UNTIL PROPERLY DISPOSED
OF.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 110F & KEEP FROM FREEZING.
KEEP CONTAINER CLOSED WHEN NOT IN USE. DO NOT REUSE EMPTY
CONTAINERS.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DO NOT BREATHE VAPS, SPRAY MIST/SANDING DUST.
WHEN SPRAY APPLIED IN OUTDOOR/OPEN MECH FILTER RESP TO REMOVE SOLID
AIRBORNE PARTICLES OF OVERSPRAY & SANDING DUST. WHEN USED IN
RESTRICTED AREAS, WEAR NI OSH/MSHA APPRVD CHEM/MECH (SUPDAT)
Ventilation:USE ONLY W/ADEQ VENT. PROVIDE GENL DILUTION/LOCAL EXHST
VENT IN VOL & PATTERN TO KEEP AIR CONTAM CONC BELOW (ING 12)
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA.
Work Hygienic Practices:REMOVE & WASH SOILED CLTHG BEFORE REUSE. WASH
HANDS BEFORE EATING, SMOKING/USING WASHROOM.
Supplemental Safety and Health
FIRE FIGHT PROC:IF EXPOSED TO FIRE/EXTREME HEAT, WATER SHOULD BE USED
TO COOL CLSD CNTNRS & PVNT PRESS BUILD-UP/POSS AUTO-IGNIT. EXPLO
HAZ:OVEREXP TO DECOMP PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE
IMMED APPARENT. OBTAIN MED ATTN. RESP PROT: FILTERS DESIGNED TO
REMOVE COMBINATION OF PARTICULATES & VAPOR. WHEN(ING 10)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:SEE ING
Vapor Density:HVR/AIR
Spec Gravity:1.29
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:65
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH MATERIALS THAT ARE INCOMPATIBLE WITH WATER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY CAUSE HAZ FUMES WHEN HEATED TO
DECOMP. FUMES MAY CONTAIN CARBON MONOXIDE, CARBON DIOXIDE & OXIDES
OF METALS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS. INCINERATE ONLY IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:7860
CAGE:HO697
CAGE:91522
CAGE:HO697
============= Composition/Information on Ingredients =============
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Other REC Limits:N/K
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9192
Ingred Name:1,1,2-TRICHLORO-1,2,2-TRIFLUOROETHANE (FREON 113) (SARA
III)
CAS:76-13-1
RTECS #:KJ4000000
Fraction by Wt: <40%
Other REC Limits:N/K
OSHA PEL:1000PPM/1250STEL
ACGIH TLV:1000PPM/1250STEL9192
Ozone Depleting Chemical:1
Ingred Name:ISOBUTANE (PROPELLANT).VP:>760 MMHG.INGREDIENT IS 21% OF
INGREDIENT 6.
CAS:75-28-5
RTECS #:TZ4300000
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PROPELLANT.VP:>760 MMHG.
CAS:68476-85-7
Fraction by Wt: <25%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: <40%
Other REC Limits:N/K
OSHA PEL:350 PPM/450 STEL
ACGIH TLV:350 PPM/450STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:BUTANE
CAS:106-97-8
RTECS #:EJ4200000
Other REC Limits:N/K
OSHA PEL:800 PPM
ACGIH TLV:800 PPM; 9192
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED OR REPEATED CONTACT MAY
CAUSE DERMATITIS.REPORTS HAVE ASSOCIATED REPEATED AND PROLONGED
OVEREXPOSURE TO SOLVENTS WITH NEUROLOGICAL AND OTHER PHYSIOLOGICAL
DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:IRRITATION,WATERING.SKIN:MAY CAUSE SKIN
IRRITATION,DERMATITIS ON PROLONGED OR REPEATED
CONTACT.INGESTION:MAY CAUSE NAUSEA.INHALATION:VAPOR HARMFUL.MAY
CAUSE DIZZINESS,HEADACHE,NAUSEA AND WATERING OF EYES.SEVERE
OVEREXPOSURE MAY CAUSE UNCONSCIOUSNESS.
Medical Cond Aggravated by Exposure:DISEASES OF THE SKIN.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH LARGE QUANTITIES OF WATER FOR AT LEAST 15
MINUTES.IF IRRITATION FROM CONTACT PERSISTS,GET MEDICAL
ATTENTION.SKIN:WASH WITH SOAP AND WATER.INGESTION:CALL HOSPITAL
EMERGENCY ROOM,POISON CONTROL CENTER OR PHYSICIAN IMMEDIATELYFOR
INSTRUCTIONS.INHALATION:IF BREATHING DIFFICULTY IS EXPERIENCED,MOVE
TO AIR FREE OF VAPORS.ADMINISTER O*2/ARTF RESP UNTIL MEDICAL
ASSISTANCE CAN BE RENDERED.
===================== Fire Fighting Measures =====================
Flash Point:N/K
Lower Limits:N/K
Upper Limits:N/K
Extinguishing Media:USE CARBON DIOXIDE,DRY POWDER OR FOAM.
Fire Fighting Procedures:WEAR PRESSURE DEMAND SCBA AND FULL PROTECTIVE
EQUIPMENT .STORAGE CONTAINERS EXPOSED TO FIRE SHOULD BE KEPT COOL
WITH WATER SPRAY TO PREVENT PRESS BUILDUP.
Unusual Fire/Explosion Hazard:DANGER.FLAM.KEEP FROM
HEAT,SPK,FLAME,IGNIT SOURCES.EXTING FLAME,PILOT
LIGHTS,STOVE,HEATER,ELEC MOTORS,ETC DURING USE/UNTIL VAP
CLEAR.BEWARE OF STATIC (SEE SUPP)
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID BREATHING VAPORS,VENTILATE AREA.FLUSH
LARGE SPILLS OF MATERIAL INTO SUITABLE RETAINING AREA OR CONTAINERS
WITH LARGE QUANTITIES OF WATER.SMALL SPILLS CAN BE ABSORBED BY
APPROPRIATE INERT ABSORBE NT.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE NEAR FLAMES OR AT
ELEVATED TEMPERATURES.CAREFULLY READ ALL CAUTIONS/DIRECTIONS ON
LABEL BEFORE USE.
Other Precautions:NO SMOKING IN AREA OF USE.DO NOT USE IN THE GEN
VICINITY OF ARC WELDING,OPEN FLAMES,HOT SURF.HEAT AND/OR UV RADIA
MAY CAUSE FORMATION OF HCL/PHOSGENE .EMPTY CONTR RETAINS
RESIDUE:FOLLOW LABEL WA RNINGS.DISPOSE OF EMPTY CONTR IAW REGS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Other Protective Equipment:VARYING APPLICATION METHODS DICTATE USE OF
ADDITIONAL PROTECTIVE SAFETY EQUIPMENT SUCH AS IMPERMEABLE
APRONS,ETC.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER USE.BEFORE
REUSE,THOROUGHLY CLEAN ANY CONTAMINATED CLOTHING/PROTECTIVE
EQUIPMENT.
Supplemental Safety and Health
BP RANGE:118-165F,48-74C.EXPLO HAZ:ELEC.CONTENTS UNDER PRESS.DO NOT
PUNCTURE,INCIN OR STORE >120F,49C.EXPOS TO HEAT/PRLNG SUN EXPOS MAY
CAUSE BURSTING.DO NOT SMOKE.HAZ DECOMP PROD:HYDROGEN CHLORIDE/FL
UORIDE,PHOSGENE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:SEE SUPP
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/K
Vapor Density:>1 (AIR=1)
Spec Gravity:1.37 (WATER=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:N/K
Appearance and Odor:AEROSOL
Percent Volatiles by Volume:93.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:N/K
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY PRODUCE
HYDROGEN CHLORIDE,HYDROGEN FLUORIDE,AND SMALL AMOUNTS OF PHOSGENE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FA1641A
CAGE:JO867
CAGE:81831
CAGE:JO867
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR. AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UN CONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ZINC OXIDE, Z52 500
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:ZINC OXIDE (SARA 313) (CERCLA) LD50: (ORAL, MOUSE) 7950
MG/KG
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: 100%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: DUST MAY CAUSE MECH IRRIT. SKIN:
MAY CAUSE SKIN IRRIT. INGEST: MOD TOXIC TO HUMANS BY INGEST. INHAL:
EFTS MAY BE DELAYED. INHAL OF FUMES MAY CAUSE METAL FUME FEVER
WHICH IS CHARACTERIZED BY FLU-L IKE SYMPS W/METALLIC TASTE, FEVER,
CHILLS, COUGH, WEAK, CHEST PAIN, MUSC PAIN & INCREASED WHITE BLOOD
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: CELL COUNT. ZINC OXIDE DUST IS
CONSIDERED TO BE OF LOW TOX & IS CLASSIFIED AS A NUISANCE
PARTICULATE BY ACGIH. HOWEVER, INHAL OF FUMES OR VERY FINE DUST MAY
CAUSE "ZINC FUME FEVER" WHICH IS CHARACTERIZED BY FLU-LIKE SYMPS
W/METALLIC TASTE, COUGH, WEAK, FATIGUE, MUSC PAIN & NAUS FOLLOWED
BY FEVER & (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH EYES W/PLENTY OF WATER FOR AT LEAST 15 MIN,
OCCASNLY LIFTING UPPER & LOWER LIDS. GET MED AID. SKIN: GET MED
AID. FLUSH SKIN W/PLENTY OF SOAP & WATER FOR AT LEAST 15 MIN WHILE
REMOVING CONT AMD CLTHG & SHOES. INGEST: IF CONSCIOUS& ALERT, GIVE
2-4 CUPFULS OF MILK OR WATER. GET MED AID. INHAL: REMOVE FROM EXPOS
TO FRESH AIR IMMED. IF NOT BRTHG GIVE ARTF RESP. IF BRTHG IS DFCLT,
(SUPDAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:SUBSTANCE IS NONCOMBUSTIBLE; USE AGENT MOST
APPROPRIATE TO EXTINGUISHING SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . MATERIAL WILL NOT BURN.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTIVE EQUIPMENT AS
INDICATED. VACUUM OR SWEEP UP MATERIAL AND PLACE INTO A SUITABLE
DISPOSAL CONTAINER. AVOID GENERATING DUSTY CONDITIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A DRY AREA.
Other Precautions:USE WITH ADEQUATE VENTILATION. MINIMIZE DUST
GENERATION AND ACCUMULATION. AVOID BREATHING DUST, VAPOR, MIST OR
GAS. AVOID CONTACT WITH EYES, SKIN AND CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
29 CFR 1010.134. ALWAYS USE A NIOSH APPROVED RESPIRATOR WHEN
NECESSARY.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
AIRBORNE CONCENTRATIONS BELOW THE PERMISSIBLE EXPOSURE LIMITS.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN EXPOSURE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MATL TO AVOID: WHEN HEATED TO 419F. EFTS OF OVEREXP: CHILLS. ONSET OF
SYMPS OCCURS ABOUT 4-12 HRS AFTER EXPOS. CHRONIC: NO INFO FOUND.
TARGET ORGANS: NONE. FIRST AID PROC: GIVE OXYGEN. GET MED AID. NO
TES TO MD: ONSET OF SYMPS MAY OCCUR 4-12 HRS AFTER EXPOSURE.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:3272F,1800C
Spec Gravity:5.68
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE OR YELLOWISH WHITE POWDER; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTS EXPLOSIVELY W/MAGNESIUM WHEN HEATED. MIXTURES OF CHLORINATED
RUBBER & ZINC OXIDE CAN EXPLODE VIOLENTLY (SUPDAT)
Stability Condition to Avoid:INCOMPATIBLE MATERIALS.
Hazardous Decomposition Products:TOXIC FUMES OF ZINC OXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE AND LOCAL REGULATIONS. NOT LISTED AS A MATERIAL BANNED FROM
LAND DISPOSAL ACCORDING TO RCRA.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ASPHALT EMULSION, F-900
CAGE:IO527
CAGE:FELDS
CAGE:IO527
============= Composition/Information on Ingredients =============
Ingred Name:NON-VOLATILE CONTENT; (NONVOLATILE MATTER)
Fraction by Wt: 47-53%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: <53%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ASPHALT; (PETROLEUM ASPHALT)
CAS:8052-42-4
RTECS #:CI9900000
OSHA PEL:N/K
ACGIH TLV:5 MG/M3 (FUME)
Ingred Name:CLAY THICKENER (INORGANIC);
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: WILL CAUSE NO MORE THAN MINOR
EYE AND SKIN IRRITATION, HOWEVER, PROLONGED OR FREQUENT SKIN
CONTACT MAY BE HARMFUL. PRODUCT IS NOT EXPECTED TO BE ACUTELY TOXIC
BY INHALATION OR INGESTION. CHRONI C: NOT APPLICABLE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE O*2/ARTF
RESP) . EYE: WASH WITH FRESH WATER FOR @ LST 15 MIN, SEE MD. SKIN:
REMOVE HEAVILY CONTAMD CLTHG & WASH SKIN THOROUGHLY W/SOAP & WATER.
DONOT USE SOLV/THINNERS. ASPHALT CAN BE REMOVED
W/VEGETABLE/MINERAL OIL. INGEST: DRINK LG AMTS OF WATER, INDUCE
VOMIT IF LG AMT CONSUMED.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL, CO*2, FOAM, WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP AS SOON AS POSSIBLE, PUT IN
DISPOSABLE CONTAINER. HYDROCARBON MATERIAL IE. KEROSENE, MINERAL
OIL CAN BE USED TO DISSOLVE REMAINING MATERIAL, ALSO MAY BE
ABSORBED WITH ABSORBENT CLAY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Other Precautions:DO NOT USE PRESSURE TO EMPTY DRUM. DO NOT WELD,
HEAT/DRILL CONTRS. REPLACE CAP OR BURN. EMPTIED CONTAINER STILL
CONTAINS HAZ MATL WHICH MAY IGNITE W/EXPLOSIVE VIOLENCE IF HEATED
SUFFICIENTLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED BUT IF IN HIGH AIRBORNE
CONC, USE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:LOCAL EXHAUST/MECH(GEN): ACCEPTABLE.
Other Protective Equipment:NONE NECESSARY.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:60@100F
Spec Gravity:1.03
Solubility in Water:READILY DISPERSIBLE
Appearance and Odor:BROWN, AND PASTY
Percent Volatiles by Volume:50
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:COMBUSTION MAY PRODUCE OXIDES OF
SULFUR, NITROGEN, CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE CONTAMINATED MATERIALS IN DISPOSABLE
CONTAINERS AND BURY IN AN APPROVED DUMPING AREA. DISPOSE OF I/A/W
FEDERAL, STATE AND LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SOLDER ALLOYS CONTAINING LEAD
Preparer's Name:D BERNIER
CAGE:GO345
CAGE:GO345
CAGE:75297
============= Composition/Information on Ingredients =============
Ingred Name:LEAD (SARA 313) (CERCLA)
CAS:7439-92-1
RTECS #:OF7525000
OSHA PEL:SEE 1910.1025
ACGIH TLV:0.15MG/M3 DUST
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:SILVER (SARA 313) (CERCLA)
CAS:7440-22-4
RTECS #:VW3500000
OSHA PEL:0.01 MG/M3
ACGIH TLV:0.1 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:BISMUTH
CAS:7440-69-9
RTECS #:EB2600000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ANTIMONY (SARA 313) (CERCLA)
CAS:7440-36-0
RTECS #:CC4025000
OSHA PEL:0.5 MG/M3
ACGIH TLV:0.5 MG (SB)/M3
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:COPPER (SARA 313) (CERCLA)
CAS:7440-50-8
RTECS #:GL5325000
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2 MG/M3 FUME
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:INDIUM
CAS:7440-74-6
RTECS #:NL1050000
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.1 MG/M3
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: OVEREXP TO LEAD MAY LEAD
TO CNS DISORDERS CHARACTERIZED BY DROWS, SEIZURES, COMA & DEATH.
EXPOS OF THIS MAGNITUDE ARE UNLIKELY. INGEST: NOT LIKELY TO OCCUR,
BUT WOULD HAVE SIMILAR EFTS A S INHALATION. CHRONIC: REPEATED
INHALATION OR INGESTION OF LEAD CAN RESULT IN SYSTEMIC POIS. NOTE:
LEAD(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: APPEARS ON THE NAVY LISTING OF
OCCUPATIONAL CHEMICAL REPRODUCTIVE HAZARDS. SEEK CONSULTATION FROM
APPROPRIATE HEALTH PROFESSIONALS CONCERNING LATEST HAZARD LIST
INFORMATION AND SAFE HANDLING AND EXPOSURE INFORMATION.
Medical Cond Aggravated by Exposure:PREEXISTING CONDITIONS OR DISORDERS
OF BLOOD AND BLOOD FORMING ORGANS, KIDNEYS, NERVES AND POSSIBLY
REPRODUCTIVE SYSTEM.
======================= First Aid Measures =======================
First Aid:EYE: FOR BURNS FLUSH IMMED W/COOL WATER FOR AT LEAST 15
MINUTES. SKIN: FOR BURNS FLUSH IMMEDIATELY W/COOL WATER. INHAL:
REMOVE PERSON FROM EXPOSURE TO FUMES. INGEST: IF THOUGHT TO BE
OVEREXPOSED, PERS ON SHOULD HAVE BLOOD LEAD ANALYSIS DONE.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Extinguishing Media:USE EXTINGUSHING MEDIA SUITABLE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:FLUX IN CORED SOLDER MAY IGNITE WHEN THE
SOLDER MELTS IN A FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:MELTED SOLDER WILL SOLIDIFY ON COOLING AND CAN
BE SCRAPED UP. USE CAUTION TO AVOID BREATHING FUMES IF GAS TORCH IS
USED TO CUT UP LGE PIECES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM SOURCES OF SULFUR. DO
NOT PLACE FLUX CORED SOLDER INTO HOT SOLDER POT BECAUSE FLUX MAY
IGNITE.
Other Precautions:AVOID BREATHING SMOKE/FUMES GENERATED DURING
SOLDERING. USE OF STRONG ACID FLUXES MAY RESULT IN LIBERATION OF
TOXIC LEAD CHLORIDE FUMES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USUALLY NOT REQUIRED. WHEN VENT IS NOT
SUFFICIENT TO REMOVE FUMES FROM THE BREATHING ZONE, A NIOSH/MSHA
APPROVED CARTRIDGE TYPE RESPIRATOR.
Ventilation:PROVIDE ADEQUATE EXHAUST VENTILATION (GENERAL &/LOCAL) TO
MEET TLV REQUIREMENTS.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA.
Work Hygienic Practices:WASH HANDS THORO AFTER HANDLING SOLDER
CONTAINING LEAD BEFORE EATING OR SMOKING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:>1(H*2O=1 @25C)
Solubility in Water:0%
Appearance and Odor:SILVER-GRAY METAL IN BAR, WIRE, RIBBON OR PREFORMED
SHAPES.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACID, STRONG OXIDIZERS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NO LEAD OR ANTIMONY ARE DETECTED IN
FUMES FROM SOLDERING BELOW 1000F(537C).
==================== Disposal Considerations ====================
Waste Disposal Methods:SOLDER CAN BE RECLAIMED. DISPOSE OF IN
ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MATCH LIGHT
CAGE:8R329
CAGE:93098
CAGE:8R329
============= Composition/Information on Ingredients =============
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED (C10-C15 SATURATED
HYDROCARBONS 97%, C10 AROMATICS 3%) (SUSP CARC IARC) * 96-3 *
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 5-25%
Other REC Limits:200 PPM EXXON
Ingred Name:HEAVY ALIPHATIC NAPHTHA *96-3*
CAS:64742-96-7
Other REC Limits:100 PPM
Ingred Name:MEDIUM ALIPHATIC NAPHTHA (AROMATIC 100), PARAFFIN-NAPTHANES
MINERAL SPIRITS
CAS:64742-88-7
Other REC Limits:100 PPM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:CHARCOAL
CAS:16291-96-6
RTECS #:FL7243500
Ingred Name:SAWDUST
Fraction by Wt: 0.5-5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. POSSIBLE SENSITIZER.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, COUGHING, SHORTNESS OF BREATH,
DIZZINESS, HEADACHES &/UNCONSCIOUSNESS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER. INGESTION: DON'T INDUCE
VOMITING. SKIN: WASH W/SOAP & WATER. INHALATION: REMOVE TO FRESH
AIR. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:>105F
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEMICAL/CO2.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A VAPOR RESPIRATOR.
Ventilation:USE GENERAL VENTILATION.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK SOLID CUBES
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, FIRE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:18230 PERCHLORIC ACID A511-500
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:PERCHLORIC ACID *97-4*
CAS:7601-90-3
RTECS #:SC7500000
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 28-40%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): >90 ML/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: CORROSIVE. CAUSES BURNS.
INGESTION: GASTROINTESTINAL BURNS. INHALATION: SEVERE IRRITATION OF
THE RESPIRATORY TRACT W/SORE THROAT & DELAYED LUNG EDEMA.
PROLONGED/REPEATED EXPOSURE MAY CAUSE TEETH EROSION, PERFORATION
OF THE NASALSEPTUM, CONJUNCTIVITIS, DERMATITIS, POSSIBLE SKIN
DESTRUCTION/ULCERATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, BURNS, SORE THROAT, COUGHING,
SHORTNESS OF BREATH, NOSEBLEEDS, NASAL CONGESTION, CHEST PAIN,
BRONCHITIS
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/PLENTY OF WATER FOR 15 MINS. SKIN:
IMMEDIATELY FLUSH W/PLENTY OF SOAP & WATER FOR 15 MINS. INGESTION:
DON'T INDUCE VOMITING. IF CONSCIOUS & ALERT, GIVE 2-4 CUPFULS OF
MILK/WA TER. INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF
NECESSARY. OBTAIN MEDICAL ATTENTION IN ALL CASES. TREAT
SYMPTOMATICALLY & SUPPORTIVELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE WATER ONLY.
Fire Fighting Procedures:USE APPROPRIATE PROTECTIVE CLOTHING TO PREVENT
CONTACT W/SKIN/EYES. WEAR SELF CONTAINED BREATHING APPARATUS TO
PREVENT CONTACT W/THERMAL DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:CONTACT W/COMBUSTIBLE MATERIALS MAY CAUSE
A FIRE. THIS MATERIAL IS A STRONGLY ACIDIC, POWERFUL OXIDIZING
SUBSTANCE. ANHYDROUS FORM OF THIS MATERIAL IS EXPLOSIVE
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PROTECTIVE EQUIPMENT. COVER W/SAND,
DRY LIME/SODA ASH & PLACE IN A CLOSED CONTAINER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE NEAR COMBUSTIBLE
MATERIALS. STORE IN A COOL, DRY PLACE. STORE IN A TIGHTLY CLOSED
CONTAINER. USE W/ADEQUATE VENTILATION.
Other Precautions:AVOID CONTACT W/CLOTHING. DON'T GET ON SKIN/IN EYES.
DON'T INGEST/INHALE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ALWAYS USE A NIOSH-APPROVED RESPIRATOR WHEN
NECESSARY. FOLLOW OSHA RESPIRATOR REGULATIONS 29CFR 1010.134.
Ventilation:USE PROCESS ENCLOSURE, LOCAL EXHAUST VENTILATION/OTHER
ENGINEERING CONTROLS TO CONTROL AIRBORNE LEVELS.
Other Protective Equipment:PROTECTIVE CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
INCOMPATIBILITIES: ACIDS/ACIDIC
ANHYDRIDE/ALCOHOLS/ANILINE/FORMALDEHYDE/ANTIMONY III
COMPOUNDS/BISMUTH/CELLULOSE/CHARCOAL/DIBUTYL SULFOXIDE/DIETHYL
ETHER/DIMETHYL SULFOXIDE/FLUORINE/GLYCERINE/LEAD OXI DE/GLYCOL
ETHERS/GLYCOLS/HYDRIODIC
ACID/HYDROGEN/HYPOPHOSPHITES/KETONES/METHYL ALCOHOL/NITROGEN
IODIDE/NITROSOPHENOL.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:102F
Melt/Freeze Pt:M.P/F.P Text:25F
Vapor Density:3.46
Spec Gravity:1.7
pH:<7
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR COLORLESS LIQUID W/NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE/COMBUSTIBLE MATERIALS, ORGANIC MATERIALS, REDUCING AGENTS,
ALKALINE MATERIALS, DEHYDRATING AGENTS, (SUPP)
Stability Condition to Avoid:EXCESSIVE HEAT, TEMPERATURES >428F.
Hazardous Decomposition Products:CHLORINE DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:OIL HOUSE PAINT 5-
Preparer's Name:THOMAS E. MAREK
CAGE:33200
CAGE:33200
============= Composition/Information on Ingredients =============
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:CAN CAUSE SEVERE IRRITATION,
REDNESS, TEARING, BLURRED VISION. SKIN:PROLONGED OR REPEATED
CONTACT CAN CAUSE MODERATE IRRITATION, DEFATTING, DERMATITIS.
INHAL:EXCESSIVE INHALATION OF VAPORS CAN CA USE NASAL & RESPIRATORY
IRRITATION, DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, HEADACHE,
POSSIBLE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:UNCONSCIOUSNESS & EVEN ASPHYXIATION.
INGEST:CAN CAUSE GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING &
DIARRHEA. ASPIRATION INTO LUNGS CAN CAUSE CHEMICAL PNEUMONITIS
WHICH CAN BE FATAL.
Medical Cond Aggravated by Exposure:NO KNOWN.
======================= First Aid Measures =======================
First Aid:SKIN:THORO WASH EXPOS AREA W/SOAP & WATER. REMOVE CONTAM
CLTHG. LAUNDER CONTAM CLTHG BEFORE REUSE. EYES:FLUSH W/LG AMTS OF
WATER FOR AT LST 15 MINS, LIFTING UPPER & LOWER LIDS OCCAS, GET MED
ATTN. ING EST:DO NOT INDUCE VOMIT. KEEP PERSON WARM & GET MED ATTN.
INHAL:REMOVE TO FRESH AIR. IF BRTHG IS DFCLT, ADMIN OXYGEN. IF
BRTHG HAS STOPPED, APPLY ARTF RESP. KEEP PERSON WARM, QUIET & GET
MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:102F,39C
Lower Limits:1%
Upper Limits:6%
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:COMBUST LIQ. VAPS ARE HVR/AIR & MAY
TRAVEL ALONG GROUND/BE MOVED BY VENT & IGNITED BY HEAT, PILOT
LIGHTS, OTHER FLAMES & IGNIT SOURCES AT LOCATIONS DIST(SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB LIQUID ON PAPER, VERMICULITE, FLOOR
ABSORBANT OR OTHER ABSORBANT MATERIAL & PICK UP W/SHOVEL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PROLONGED OR REPEATED SKIN
CONTACT. KEEP AWAY FROM HEAT, SPARKS, OPEN FLAMES. USE W/ADEQUATE
VENTILATION.
Other Precautions:PAINT, COMBUSTIBLE LIQUID UN 1263. NO SPECIAL
MARKINGS REQUIRED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED SELF-CONTAINED RESPIRATOR IF
TLV IS REACHED.
Ventilation:LOCAL EXHAUST AS NEEDED TO REMAIN BELOW PEL.
Other Protective Equipment:BARRIER CREAM, EMERGENCY EYE WASH AND DELUGE
SHOWER WHICH MEET ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPEC GRAV:1.25-1.35 (H*2O=1). EXPLO HAZ:FROM MATERIAL HANDLING POINT.
EYE PROT:& FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:300F,149C
Vapor Pres:SEE ING 1
Vapor Density:HVR/AIR
Spec Gravity:SUPP DATA
Evaporation Rate & Reference:70 (ETHER=1)
Solubility in Water:NONE
Appearance and Odor:WHITE OPAQUE LIQUID; MINERAL SPIRITS ODOR.
Percent Volatiles by Volume:35-45
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
DIOXIDE &/OR CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE UNDER SAFE CONDITIONS. DISPOSE OF
I/A/W LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SILVER SOLDER FLUX NO. 601
CAGE:KO887
CAGE:56406
CAGE:KO887
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM FLUOROHYDROBATE
CAS:14075-53-7
RTECS #:ED2800000
Fraction by Wt: 35-45%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2.5 MG/M3 AS F
ACGIH TLV:2.5 MG/M3 AS F
Ingred Name:POTASSIUM TETRABORATE
CAS:1332-77-0
Fraction by Wt: 15-25%
Other REC Limits:TLV 5.0 MG/M3
Ingred Name:BORIC ACID
CAS:10043-35-3
RTECS #:ED4550000
Fraction by Wt: 15-30%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG BORATES/M3
ACGIH TLV:5 MG BORATES/M3
Ingred Name:POTASSIUM FLUOBORATE
CAS:14075-53-7
RTECS #:ED2800000
Fraction by Wt: 7-15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2.5 MG/M3 AS F
ACGIH TLV:2.5 MG/M3 AS F
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:ACUTE: OVEREXPOSURE MAY CAUSE
SALIVATION, COUGHING, CHOKING, CHILLS. CHRONIC: MAY CAUSE WEIGHT
LOSS, BRITTLE BONES, ANEMIA, WEAKNESS, STIFF JOINTS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SALIVATION, COUGHING, CHOCKING, CHILLS, WEIGHT
LOSS, BRITTLE BONES, ANEMIA, WEAKNESS, STIFF JOINTS.
Medical Cond Aggravated by Exposure:ANY WEAKNESS OF THE LUNGS, KIDNEYS,
LIVER WILL BE AGGRAVATED.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. GET MEDICAL
ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. WASH SKIN WITH SOAP
AND WATER. INHALATION: MOVE TO FRESH AIR. INGESTION> DRINK WATER OR
MILK. GET ME DICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NOT NEEDED.
Fire Fighting Procedures:NORMAL CAUTION WHEN DEALING WITH FLUX
CHEMICALS.
Unusual Fire/Explosion Hazard:WILL RELEASE BORON TRIOXIDE FUMES UPON
DECOMPOSITION.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP PASTE AND FLUSH RESIDUAL MATERIAL
WITH LOTS OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE IN GLASS OR PORCELAIN
CONTAINERS. AVOID CONTACT WITH EYES, SKIN, AND CLOTHING. WASH
THOROUGHLY AFTER HANDLING.
Other Precautions:KEEP CONTAINERS AWAY FROM EXCESSIVE HEAT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH APPROVED RESPIRATOR IN ABSENCE OF
PROPER VENTILATION.
Ventilation:PROVIDE LOCAL EXHAUST AND/OR MECHANICAL (GENERAL) AS
NECESSARY TO REMOVE FUMES TO WITHIN RECOMMENDED LIMITS.
Other Protective Equipment:WEAR RUBBER APRON TO PROTECT SKIN AND
CLOTHING.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.6
Evaporation Rate & Reference:0.3
Solubility in Water:MODERATE
Appearance and Odor:WHITE ODORLESS PASTE.
Percent Volatiles by Volume:30
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
GLASS OR PORCELAIN.
Stability Condition to Avoid:EXCESSIVE HEAT.
Hazardous Decomposition Products:B2O3 FUMES, KBF4.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LINE PIPE & COUPLINGS CARBON STEEL, 4C020
CAGE:HO954
CAGE:61497
CAGE:HO954
============= Composition/Information on Ingredients =============
Ingred Name:PHOSPHOROUS (YELLOW) (SARA III)
CAS:7723-14-0
RTECS #:TH3500000
Fraction by Wt: 0.03%
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.1 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: 0.3% MAX
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:SULFUR. PEL AND TLV AS SO*2.
CAS:7704-34-9
RTECS #:WS4250000
Fraction by Wt: 0.03%
OSHA PEL:2 PPM; 5 PPM STEL
ACGIH TLV:2 PPM; 5 PPM STEL
Ingred Name:SUPP DATA:SYNERGISTICALLY W/INHAL OF OXIDES, FUMES OR DUST
OF THIS PRODUCT TO CAUSE TOXIC EFFECTS.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:AT LEAST 15 MINS TO REMOVE PARTICLES. SEEK
MD. INGEST:CALL MD IMMEDIATELY .
RTECS #:9999999ZZ
Ingred Name:VENT:EXCESSIVE DUST OR FUME EXPOSURE.
RTECS #:9999999ZZ
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 1.35%
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:IRON OXIDE
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 98% MIN
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
Ingred Name:ALUMINUM (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 0.01%MIN
OSHA PEL:15MG/M3 DUST/5 FUME
ACGIH TLV:10MG/M3 DUST; 9192
Ingred Name:GRAPHITE, SYNTHETIC
CAS:7440-44-0
RTECS #:FF5250100
Fraction by Wt: 0.29% MX
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CHRONIC INHAL OF HIGH CONC OF IRON
OXIDE FUMES/DUST MAY LEAD TO A BENIGN PNEUMOCONIOSIS (SIDEROSIS).
INHAL OF HIGH CONC OF FERRIC OXIDE MAY POSS ENHANCE THE RISK OF
LUNG CANCER DEVELOPMENT IN WORKERSEXPOSED TO PULM CARCIN. THE
INHAL OF HIGH CONC OF FRESHLY FORMED OXIDE FUMES/DUST OF MANGANESE,
(SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:COPPER, LEAD &/OR ZINC IN THE RESP
PARTICLE SIZE RANGE CAN CAUSE AN INFLUENZA-LIKE ILLNESS TERMED
METAL FUME FEVER. TYPICAL SYMPS LAST 12-48 HRS & ARE CHARACT BY
METALLIC TASTE IN MOUTH/DRYNE SS/IRRIT OF THE THROAT, FOLLOWED BY
WEAKNESS/MUSCLE PAIN/FEVER/ CHILLS. CONTINUOUS EXPOS TO HIGH CONC
OF (SEE SUPP DATA)
Medical Cond Aggravated by Exposure:INDIVIDUAL W/CHRONIC RESPIRATORY
DISORDERS (I.E. ASTHMA, CHRONIC BRONCHITIS, EMPHYSEMA, ETC) MAY BE
ADVERSELY AFFECTED BY ANY FUME OR AIRBORNE PARTICULATE MATTER
EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHAL:FOR OVEREXPOS TO AIRBORNE FUMES/ PARTICULATES, REMOVE
EXPOSED PERS TO FRESH AIR. IF BRTHG IS DFCLT/HAS STOPPED,
ADMINISTER ARTF RESP/O2 AS INDICATED. SEEK MD PROMPTLY. TREAT METAL
FUME FEVER BY BED REST/ADMINISTER A PAIN/FEVER REDUCING
MEDICATION. SKIN:IF THERMAL BURN HAS OCCURRED, FLUSH AREA W/COLD
WATER. SEEK MD. FOR MECH ABRASIONS, SEEK MD. EYE:FLUSH W/LGE AMTS
OF WATER FOR(SEE INGRED 9)
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE CONDITIONS .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT FLAMMABLE OR COMBUSTIBLE. STEEL
PRODUCTS IN THE SOLID STATE PRESENT NO FIRE OR EXPLOSION HAZARD AND
DO NOT CONTRIBUTE TO THE COMBUSTION OF OTHER MATERIALS.
================== Accidental Release Measures ==================
Spill Release Procedures:NOT APPLICABLE TO STEEL IN SOLID STATE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:OPERATIONS W/THE POTENTIAL FOR
GENERATING HIGH CONCENTRATION OF AIRBORNE PARTICULATES SHOULD BE
EVALUATED & CONTROLLED AS NECESSARY.
Other Precautions:AVOID BREATHING METAL FUMES &/OR DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED DUST/FUME RESPIRATORS SHOULD
BE USED TO AVOID EXCESSIVE INHAL OF PARTICULATES. APPROPRIATE
RESPIRATOR SELECTION DEPENDS ON THE MAGNITUDE OF EXPOSURE.
Ventilation:LOC EXHAUST VENT SHOULD BE PROVIDED WHEN WELDING, BURNING,
SAWING, BRAZING, GRINDING, MACHINING TO PVNT (SEE INGRED 10)
Other Protective Equipment:ADDITIONAL PROTECTIVE EQUIPMENT &/OR
CLOTHING MAY BE REQUIRED TO CONTROL EXPOSURES.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MP:BASE METAL-2750F; METALLIC COATING-N/A. EFTS OF OVEREXP:MANGANESE
CAN CAUSE CNS DISORDERS & "MANGANESE PNEUMONIA". FIBROSIS OF LUNG
TISSUE FROM MANGANESE EXPOS HAS ALSO BEEN REPORTED FOR PRODS CONT
AINING MANGANESE ONLY. LONGTERM INHAL EXPOS TO HIGH CONC
(OVEREXPOS) TO PNEUMOCONIOTIC AGENTS MAY ACT (SEE INGRED 8)
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:SUPP DATA
Spec Gravity:7.85
Solubility in Water:NOT SOLUBLE
Appearance and Odor:METALLIC GRAY SOLID; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WILL REACT W/STRONG ACID TO LIBERATE HYDROGEN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:AT TEMPERATURES ABOVE THE MELTING
POINT, MAY LIBERATE FUMES CONTAINING OXIDES OF IRON AND ALLOYING
ELEMENTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE W/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:INSECT STING RELIEF SWABS, 2632
CAGE:EO366
CAGE:EO366
CAGE:6P489
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2,2',2"-NITRILOTRI-; (TRIETHANOLAMINE)
CAS:102-71-6
RTECS #:KL9275000
Fraction by Wt: 30%
OSHA PEL:N/K
ACGIH TLV:5 MG/M3
Ingred Name:ETHYL ALCOHOL
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 30%
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ingred Name:AMMONIUM, ALKYLDIMETHYLBENZYL-, CHLORIDE; (BENZALKONIUM
CHLORIDE)
CAS:8001-54-5
RTECS #:BO3150000
Fraction by Wt: 0.1%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT MAY RESULT IN IRRITATION
AND REDNESS OF EYES. INHALATION MAY CAUSE IRRITATION OF NASAL
PASSAGES AND THROAT. INGESTION MAY CAUSE GASTRIC DISTURBANCES AND
INTOXICATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN: FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD . EYES: FLUSH
IMMEDIATELY WITH LARGE AMOUNTS OF WATER. IF REDNESS OR IRRITATION
PERSISTS, CONTACT MD. INHAL: MOVE TO FRESH AIR AT ONCE. IF BREATHI
NG HAS STOPPED, PERFORM ARTIFICIAL RESPIRATION AND CONTACT MD
IMMEDIATELY. INGEST: CONTACT MD IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:78.0F,25.6C
Extinguishing Media:WATER FOG, CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. PICK UP SWABS
AND TRANSFER TO SUITABLE WASTE DISPOSAL CONTAINER. FLUSH SPILL AREA
WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV IS EXCEEDED, USE NIOSH APPROVED AIR
RESPIRATOR WITH ORGANIC VAPOR CARTRIDGE.
Ventilation:GENERAL MECHANICAL. LOCAL EXHAUST MAY BE REQUIRED IF TLV IS
EXCEEDED.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
PROTECTIVE CLOTHING AS NECESSARY TO PREVENT EXCESSIVE CONTACT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:178F,81C
Solubility in Water:MISCIBLE
Appearance and Odor:PAD SATURATED WITH CLEAR, COLORLESS LIQUID; ALCOHOL
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC GASES MAY BE GENERATED DURING
FIRE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:122897, QUALCHEM 87934 MIL-PRF-87937C TYPE IV
CAGE:UO292
CAGE:UO292
Contract Num:SP0450-01-M-D563
CAGE:07XT7
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Ingred Name:DIPROPYLENE GLYCOL MONOMETHYL ETHER
CAS:34590-94-8
RTECS #:JM1575000
OSHA PEL:600 MG/M3;100 PPM
ACGIH TLV:606 MG/M3;100 PPM
ACGIH STEL:909 MG/M3;150 PPM
Ingred Name:ETHOXYLATED NONPHENOL (POLY(OXY-1,2-ETHANEDIYL),
.ALPHA.-(NONYLPHENYL)-.OMEGA.-HYDROXY-, BRANCHED)
CAS:68412-54-4
Ingred Name:COCOAMIDE DEA
CAS:68603-42-9
RTECS #:GG6200000
Ingred Name:CYCLIC C21 DICARBOXYLIC POTASSIUM SALT (CAS # 68127-33-3)
Ingred Name:DIPROPYLENE GLYCOL MONOBUTYL ETHER(DIPROPYLENE GLYCOL
BUTOXY ETHER)
CAS:29911-28-2
RTECS #:UA8200000
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: PROLONGED CONTACT MAY IRRITATE
OR DRY THE SKIN CAUSING DERMATITIS. EYE: MAY CAUSE IRRITATION AND
BLURRED VISION. INGESTION: MAY CAUSE IRRITATION OF THE GASTRIC
LINING. INHALATION: HIGH VAPOR CON CENTRATIONS MAY CAUSE HEADACHES,
DIZZINESS, ANESTHESIA AND OTHER CENTRAL NERVOUS SYSTEM EFFECTS.
Effects of Overexposure:SKIN: IRRITATION, DRY SKIN, DERMATITIS.
EYE:IRRITATION AND BLURRED VISION. INGESTION: IRRITATION OF THE
GASTRIC LINING. INHALATION: HEADACHES, DIZZINESS, ANESTHESIA AND
OTHER CENTRAL NERVOUS SYSTEM E FFECTS.
Medical Cond Aggravated by Exposure:MAY AGGRAVATE EXISTING SKIN
CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. ADMINISTER OXYGEN OR CPR AS
NECESSARY. CALL A PHYSICIAN. EYE: WASH WITH COPIOUS AMOUNTS OF
WATER FOR AT LEAST 15 MINUTES. IF IRRITATION STILL OCCURS, SEEK
MEDICAL ATTE NTION. SKIN: WASH AFFECTED AREAS WITH SOAP AND WATER.
REMOVE CONTAIMINATED CLOTHING. IF IRRITATION CONTINUES, CONTACT A
PHYSICIAN. INGESTION: GIVE SEVERAL GLASSES OF WATER. DO NOT INDUCE
VOMITING. SEE K MEDICAL ATTENTION. GENERAL PROCEDURES: TREAT AS AN
INDUSTRIAL DEGREASER WHICH CONTAINS SOAP AND GLYCOL ETHERS.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE TO BOILING
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:ANY APPLICABLE TO PRIMARY CAUSE OF THE FIRE.
Fire Fighting Procedures:COOL BARRELS OF PRODUCT WITH WATER TO PREVENT
OVERHEATING OF MATERIAL AND BURSTING OF DRUMS.
Unusual Fire/Explosion Hazard:NO HAZARDS RELATED TO PRODUCT.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE SPILL AND ADD A COMMERCIALLY AVAILABLE
ABSORBENT. PLACE USED ABSORBENT INTO A METAL TRASH BARREL FOR
DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL DRY PLACE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NEEDED UNDER NORMAL CONDITIONS WITH
ADEQUATE VENTILATION.
Ventilation:USE IN A WELL VENTILATED ROOM WITH A COMPLETE AIR CHANGE
EVERY 1/2 HOUR.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:=100.C, 212.F
Melt/Freeze Pt:=0.C, 32.F
Spec Gravity:1.00
pH:7.0-9.0
VOC Grams/Liter:1.
Viscosity:NE
Evaporation Rate & Reference:1.2 (WATER=1.0)
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS TO LIGHT AMBER LIQUID, MILD ODOR
Percent Volatiles by Volume:80
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, OXIDES.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE.
Conditions to Avoid Polymerization:AVIOD HEAT AND FREEZING
TEMPERATURES.
=================== Toxicological Information===================
Toxicological Information:PRODUCT CONTAINS NO KNOWN CARCINOGENS. CAUSES
NO KNOWN BIRTH DEFECTS. PRODUCT CONTAINS NO KNOWN INGREDIENTS THAT
WILL INTERFRE WITH REPRODUCTION. PRODUCT IS NOT A MUTAGEN.
===================== Ecological Information =====================
Ecological:ECOTOXICOLOGICAL INFORMATION: PRODUCT CONTAINS SURFACTANTS
THAT MAY CAUSE IT TO DISPERSE IN WATER. LOCALIZED HIGH
CONCENTRATIONS OF THIS PRODUCT MAY CAUSE FISH KILL. NO PERSISTENT
EFFECTS WILL RESULT.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. CONTAINER MAY BE SENT TO A COMMERICAL DRUM
RECYCLER. RECOMMEND TRIPLE RINSE WITH WATER BEFORE DRUMS ARE
TRANSFERRED TO RECYCLER.
=================== MSDS Transport Information ===================
Transport Information:NOT REGULATED FOR TRANSPORTATION.
===================== Regulatory Information =====================
SARA Title III Information:SEC 302 EXTREMELY HAZARDOUS SUBSTANCES:
NONE. SEC 311/312 HAZARDOUS SUBSTANCES: DIPROPYLENE GLYCOL
MONOMETHYL ETHER, DIPROPYLENE GLYCOL MONOBUTYL ETHER. SEC 313 TOXIC
CHEMICALS: NONE. CERCLA RQ: NONE.
Federal Regulatory Information:TSCA STATUS: ALL CHEMICALS LISTED.
State Regulatory Information:CALIFORNIA PROP 65: CONTAINS NO PRODUCTS
RECOGNIZED BY THE STATE OF CALIFORNIA TO CAUSE CANCER AND OR BIRTH
DEFECTS OR REPRODUCTIVE HARM. STATE RIGHT TO KNOW ACT:DIPROPYLENE
GLYCOL MONOMETHYL ETHER, D IPROPYLENE GLYCOL MONOBUTYL ETHER ARE
LISTED BY NEW JERSEY AS HAZARDOUS MATERIALS.
======================= Other Information =======================
======================================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS & COPPER OVERALL COMPOSITION
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PEROXIDASE SHEATH
CAGE:59426
CAGE:59426
============= Composition/Information on Ingredients =============
Ingred Name:PROPYLENE GLYCOL
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: 30.9%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) = 20 G/KG
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE/SKIN: MAY CAUSE IRRITATION
Explanation of Carcinogenicity:NONE OF THE MATERIALS ARE LISTED AS
CARCONOGEN BY NTP, IARC, OSHA
Effects of Overexposure:IRRITATION OF EYES AND SKIN.
Medical Cond Aggravated by Exposure:EYE OR SKIN DISORDERS MAY BE
AGGRAVATED BY EXPOSURE
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH WITH WATER FOR 15 MINUTES. CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE WATER FOG, FOAM, OR DRY CHEMICAL AS APPROPRIATE
FOR SURROUNDINGS.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:TAKE UP WITH ABSORBANT MATERIAL AND PLACE IN A
DISPOSABLE CONTAINER.
Neutralizing Agent:NONE MENTIONED
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE.
Other Precautions:CONTACT LENSES SHOULD NOT BE WORN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:EYE WASH AND SAFETY SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT
Hazardous Decomposition Products:CARBON DIOXIDE AND CARBON MONOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
REGULATIONS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:BAXTER 10% BUFFERED FORMALIN FIXATIVE C4320-90BR
CAGE:63862
CAGE:63862
============= Composition/Information on Ingredients =============
Ingred Name:FORMALDEHYDE, FORMALIN (SUSPECTED HUMAN CARCINOGEN BY IARC;
ACGIH; SUSPECTED CARCINOGEN BY NTP; IARC - GROUP 2A) *97-4*
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: 4%
ACGIH TLV:0.37 MG/CUM IC (2A)
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:METHANOL (METHYL ALCOHOL), COLUMBIAN SPIRITS *97-4*
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 1%
Other REC Limits:200 PPM
OSHA PEL:200 PPM
ACGIH TLV:200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PHOSPHORIC ACID, MONOSODIUM SALT, MONOHYDRATE *97-3*
CAS:10049-21-5
Fraction by Wt: 0.4%
Ingred Name:SODIUM PHOSPHATE, DIBASIC, ANHYDROUS, DISODIUM PHOSPHATE
CAS:7558-79-4
RTECS #:WC4500000
Fraction by Wt: 0.65%
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 90%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RATS): 800 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: STRONG IRRITANT. ALLERGIC
REACTIONS. LACHRYMATOR. INGESTION: DAMAGE TO GI
TRACT/KIDNEYS/LIVER.FETAL ABORTION IF PREGNANT. METHANOL: MAY BE
FATAL/CAUSE BLINDNESS. INHALATION: RESPIRATORY TRA CT IRRITANT;
CHEMICAL PNEUMONIA. CNS DEPRESSION. PROLONGED/REPEATED EXPOSURE MAY
CAUSE RESPIRATORY IMPAIRMENT.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, LOW BLOOD PRESSURE, LOSS OF
CONSCIOUSNESS, DIFFICULTY BREATHING
Medical Cond Aggravated by Exposure:RESPIRATORY CONDITIONS, SKIN
DISORDERS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WASH WELL W/SOAP &
WATER. INGESTION: GIVE WATER IF CONSCIOUS, TO DILUTE CONCENTRATION.
INHALATION: REMOVE TO FRESH AIR & TREAT SYMPTOMATICALLY. OBTAIN
MEDICAL AT TENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:185F
Lower Limits:7
Upper Limits:73
Extinguishing Media:CO2, DRY CHEMICAL, WATER SPRAY, ALCOHOL FOAM
Fire Fighting Procedures:USE NIOSH APPROVED SELF CONTAINED BREATHING
APPARATUS.
Unusual Fire/Explosion Hazard:FORMALDEHYDE VAPORIZES READILY FROM AIR &
IS FLAMMABLE IN AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. WEAR SUITABLE
PROTECTIVE CLOTHING. ABSORB LIQUID W/VERMICULITE/OTHER ABSORBENT.
PLACE IN PLASTIC BAG IN FIBER CARTON. WASH AREA WELL W/WATER.
Neutralizing Agent:VYTAC 10F 10% FORMALIN NEUTALIZER C4360 & C4361-1
ABSORPTION SYSTEM MAY BE USED.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE. KEEP
TIGHTLY CLOSED.
Other Precautions:PREVENT CONTACT W/SKIN. FULL BODY PROTECTION SHOULD
BE WORN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:OSHA 29CFR 1910.1048 G FORMALDEHYDE AIR
FILTERING RESPIRATOR/A SELF CONTAINED BREATHING APPARATUS MAY BE
REQUIRED IF THE TLV IS EXCEEDED.
Ventilation:LOCAL EXHAUST/ADEQUATE GENERAL VENTILATION
Other Protective Equipment:NIOSH APPROVED WORK CLOTHES, EYEWASH
STATION, QUICK DRENCH STATION
Work Hygienic Practices:WASH HANDS W/SOAP & WATER AFTER USE.
Supplemental Safety and Health
PH: 6.8-7.2. INCOMPATIBILITIES: TANNIN, GELATIN, BISULFIDES, IRON
PREPARATION, SALTS OF COPPER, ARSENIC, STRONG ACIDS-HYDROGEN
CHLORIDE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Vapor Pres:25
Vapor Density:1.02
Spec Gravity:1
pH:(SUPP)
Solubility in Water:MISCIBLE
Appearance and Odor:COLORLESS LIQUID W/A PUNGENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS: PEROXIDES/HYDROGEN/NITROGEN/PERFORMIC ACID/PERCHLORIC
ACID/STRONG ALKALIS/PHENOL/ANALINE/UREA/ (SUPP)
Stability Condition to Avoid:IGNITION SOURCES
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:MAY BE MIXED W/A COMBUSTIBLE SOLVENT & BURNED IN
A CHEMICAL INCINERATOR EQUIPPED W/AN AFTERBURNER & SCRUBBER. MAY BE
NEUTRALIZED ON SITE. DISPOSE OF IAW/LOCAL, STATE & FEDERAL
REGULATIONS. UN2209, III .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DIESEL FUEL
Preparer's Name:NONE
CAGE:TRUMA
CAGE:0LA99
CAGE:TRUMA
============= Composition/Information on Ingredients =============
Ingred Name:DIESEL FUEL, (PETROLEUM HYDROCARBON DISTILLATE, ALIPHATIC
AND AROMATIC HYDROCARBON)
CAS:68476-34-6
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (MIST) 9394
Ingred Name:PRODUCT INCLUDES THE FOLLOWING INGREDIENTS; NUMBERS 3, 4,
5, 6, 7, 8, AND 9.
RTECS #:9999999ZZ
Ingred Name:BENZENE (SARA III)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: <0.1-1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1PPM/5PPM STEL
ACGIH TLV:10 PPM; A2; 9394
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:N-HEPTANE
CAS:142-82-5
RTECS #:MI7700000
Fraction by Wt: <1-2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9394
Ingred Name:HEXANE (N-HEXANE)
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: <1-2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:50 PPM
ACGIH TLV:50 PPM; 9394
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:HEXANE ISOMERS
Fraction by Wt: <1-3%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NAPHTHALENE (SARA III)
CAS:91-20-3
RTECS #:QJ0525000
Fraction by Wt: <1-2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 PPM/15 STEL
ACGIH TLV:10 PPM/15 STEL; 9394
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:N-NONANE
CAS:111-84-2
RTECS #:RA6115000
Fraction by Wt: <1-3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM
ACGIH TLV:200 PPM; 9394
Ingred Name:N-OCTANE
CAS:111-65-9
RTECS #:RG8400000
Fraction by Wt: <1-2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:300 PPM/375 STEL
ACGIH TLV:300 PPM/375STEL;9394
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS UNKNOWN.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: EYES: IRRITATION,
CONJUCTIVITIS. SKIN: IRRITATION, DERMATITIS, INFECTION. INJECTION
UNDER SKIN IS EMERGENCY. INHALATION: RESPIRATORY TRACT
IRRITATION,CNS EFFECTS, CONVULSIONS,COMA,DEATH. INGEST ION:
HARMFUL/FATAL IF SWALLOWED, GI DISTURBANCES. CHRONIC: REPEATED
CONTACT MAY CAUSE DERMATITIS, BEHAVIORAL CHANGES.
Explanation of Carcinogenicity:CONTAINS B[71-43-2] WHICH IS
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:EYES: IRRITATION, CONJUNCTIVITIS. SKIN:
IRRITATION, DEFATTING, REDNESS, INFLAMMATION, DERMATITIS,
INFECTION, SWOLLEN-DISCOLORED-EXTREMELY PAINFUL TISSUE. INHALATION:
IRRITATION, CNS EFFECTS, DIZZINESS , NAUSEA, HEADACHE, CONVULSIONS,
COMA, DEATH. INGESTION: GI DISTURBANCES, NAUSEA, VOMITING,
DIARRHEA, CNS EFFECTS.
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN, HEART,
CENTRAL NERVOUS SYSTEM AND RESPIRATORY DISORDERS MAY BE AGGRAVATED
BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. IF IRRITATION
PERSISTS GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH AREA WITH SOAP AND WATER. IF INJECTED UNDER SKIN, GET MEDICAL
ATTENTION.INHALATION: MOVE TO FRESH AIR. SUPPORTBREATHING AS
NEEDED. GET MEDICAL ATTENTION. INGESTION: DO NOT INDUCE VOMITING.
GIVE VEGETABLE OIL OR CHARCOAL SLURRY TO RETARD ABSORPTION.GET
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:125 TO 190F
Autoignition Temp:Autoignition Temp Text:495F
Lower Limits:0.4
Upper Limits:8.0
Extinguishing Media:DRY CHEMICAL, FOAM, CARBON DIOXIDE.
Fire Fighting Procedures:USE WATER TO COOL FIRE-EXPOSED CONTAINERS,
STRUCTURES, PROTECT PERSONNEL.IF SPILL NOT IGNITED,VENTILATE
AREA,DISPERSE VAPORS/PROTECT PERSONNEL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:CONTAINERS MAY EXPLODE IN HEAT OF
FIRE.VAPORS FORM EXPLOSIVE MIXTURES WITH AIR AT ROOM
TEMPERATURE.VAPORS MAY SPREAD TO DISTANT IGNITION SOURCES AND FLASH
BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. CONTAIN
SPILL. STOP LEAK, RECOVER FREE LIQUID. ABSORB LIQUID WITH
APPROPRIATE ABSORBENT. PREVENT SPILL FROM ENTERING SEWERS, STORM
DRAINS, OTHER DRAINAGE SYSTEMS ANDNATURAL WATERWAYS. CONTACT
APPROPRIATEAGENCIES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS IN COOL,
DRY, ISOLATED, WELL VENTILATED AREA AWAY FROM HEAT, SOURCES OF
IGNITION, INCOMPATIBLE MATERIALS.
Other Precautions:USE NON-SPARKING TOOLS AND EXPLOSION PROOF EQUIPMENT.
GROUND LINES, CONTAINERS, AND OTHER EQUIPMENT USED DURING PRODUCT
TRANSFER TO REDUCE POSSIBILITY OF STATIC INDUCED SPARK. DO NOT LOAD
INTO CONTAIN ERS WHICH CONTAINED LOW FLASH MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATORY PROTECTION
IN AREAS EXCEEDING EXPOSURE LIMITS.TYPE DETERMINED BY
CONTAMINANTS,DEGREE OF POTENTIAL EXPOSURE AND PUBLISHED RESPIRATORY
PROTECTION FACTORS.SHOULD BE AV AILABLE FOR NONROUTINE AND
EMERGENCY USE
Ventilation:PROVIDE ADEQUATE VENTILATION THAT WILL MAINTAIN VAPOR
CONCENTRATIONS TO LEVELS BELOW ALLOWABLE EXPOSURE LIMITS.
Other Protective Equipment:WEAR IMPERVIOUS CLOTHING AND BOOTS IF
NEEDED. PROVIDE EYE WASH STATION AND SAFETY SHOWER IN WORK AREA.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
DO NOT WEAR CONTACT LENSES WHEN WORKING AROUND THIS PRODUCT. NEVER
SIPHON BY MOUTH. FOR USE AS A MOTOR FUEL ONLY. DO NOT USE AS A
CLEANING SOLVENT OR FOR OTHER NON-MOTOR FUEL USE. DO NOT
PRESSURIZE, C UT, WELD, BRAZE, SOLDER, DRILL ON OR NEAR THIS
CONTAINER. EMPTY CONTAINER CONTAINS RESIDUE, MAY EXPLODE IN HEAT OF
FIRE.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:325 TO 700F
Vapor Pres:<0.1 PSI
Vapor Density:3-7(AIR=1)
Spec Gravity:0.84-0.93
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR TO STRAW YELLOW LIQUID. KEROSENE ODOR.
Percent Volatiles by Volume:NEG
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZING AGENTS (PEROXIDE, PERMANGANATE, DICHROMATE,
CHLORINE, ETC.), STRONG ACIDS, CAUSTICS AND HALOGENS.
Stability Condition to Avoid:AVOID HEAT, SPARKS, OPEN FLAME, STATIC
ELECTRICITY,OTHER IGNITION SOURCES.PREVENT VAPOR ACCUMULATION.DO
NOT SWITCH LOAD.
Hazardous Decomposition Products:COMBUSTION MAY PRODUCE CARBON
MONOXIDE, CARBON DIOXIDE, REACTIVE HYDROCARBONS (ALDEHYDES,
AROMATICS, ETC.) COMPOUNDS.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS. IF SPILL ENTERS INTO OR UPON NAVIGABLE
WATERS, THE CONTIGUOUS ZONE, OR ADJOINING SHORELINES, CONTACT
NATIONAL RESPONSE CENTER AT 800-424-8802.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ALUMINUM WIRE AND CUT LENGTHS
CAGE:34920
CO
CAGE:34920
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM (SARA 313)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 80-99.7%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 DUST
ACGIH TLV:10 MG/M3 DUST; 9596
Ingred Name:CHROMIUM (SARA 313) (CERCLA)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: .05-.35%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3; 9596
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:COPPER (SARA 313) (CERCLA)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: .2-4.7%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2 MG/M3 FUME; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:MANGANESE (SARA 313)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: .01-5.9%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C, 5 MG/M3 (FUME)
ACGIH TLV:0.2 MG/M3; 9596
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: .06-13%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9596
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: .01-.2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9596
Ingred Name:ZINC (SARA 313) (CERCLA)
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: .05-.25%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:OZONE (SARA 302)
CAS:10028-15-6
RTECS #:RS8225000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 PPM
ACGIH TLV:C 0.1 PPM; 9596
Ingred Name:NITRIC OXIDE (SARA 302)
CAS:10102-43-9
RTECS #:QX0525000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:25 PPM
ACGIH TLV:25 PPM; 9596
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:NITROGEN DIOXIDE (SARA 302)
CAS:10102-44-0
RTECS #:QW9800000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 5 PPM
ACGIH TLV:3 PPM/5 STEL; 9596
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT GIVEN FOR PRODUCT AS A WHOLE
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION IS NOT LIKELY UNLESS
MATERIAL IS MACHINED, WELDED OR REMELTED. MAY IRRITATE EYES WHEN
WELDING OR PLASMA CUTTING. EXPOSURE TO ZINC OXIDE FUME CAN RESULT
IN METAL FUME FEVER. RECOVERY IS USUA LLY COMPLETE IN 24-48 HOURS.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:RESPIRATORY TRACT IRRITATION, EYE IRRITATION,
FLU-LIKE SYSPTOMS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH WITH SOAP AND WATER. IF IRRITATION PERSIST, GET MEDICAL
ATTENTION. INH ALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. GET
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:DRY POWDER OR SAND
Fire Fighting Procedures:DO NOT USE WATER OR HALOGEN ON DUST FUMES.
DAMP ALUMINUM DUST MAY SPONTANEOUSLY HEAT WITH LIBERATION OF
HYDROGEN TO FORM EXPLOSIVE AIR MIXTURES.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:HDO NOT TOUCH CAST ALUMINUM METAL OR
HEATED ALUMINUM PRODUCT WITHOUT KNOWING METAL TEMP. ALUMINUM
EXPERIENCES NO COLOR CHANGE DURING HEATING.
Other Precautions:ALUMINUM POWDER MUST BE SHIPPED AND PACKAGED AS A
FLAMMABLE SOLID. SOME ALUMINUM SCRAP MAY BE CONTAMINATED WITH OIL
AT LEVELS GREATER THAN 1%. MELTING WOULD GENERATE OIL VAPORS WHICH
COULD BE IRRITATI NG.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURE MAY OR DOES EXCEED OCCUPATION
EXPOSURE LIMITS USE A NIOSH-APPROVED RESPIRATOR TO PREVENT
OVEREXPOSURE. IN ACCORD WITH 29 CFR 1910.134 USE EITHER AN
ATMOSPHERE-SUPPLYING RESPIRATOR OR AN AI R-PURIFYING RESPIRATOR.
Ventilation:TO BE DETERMINED BY NATURE OF THE PROCESSING ACTIVITY BEING
PERFORMED.
Other Protective Equipment:APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT IS
REQUIRED WHEN MELTING, CASTING, MACHINING, FORGING OR OTHERWISE
PROCESSING.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
VAPOR DEGREASER MUST BE PROPERLY MAINTAINED TO LIMIT ACCUMULATION OF
ALUMINUM FINES WHICH COULD RESULT IN FIRE OR EXPLOSION.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NOT GIVEN
Melt/Freeze Pt:M.P/F.P Text:950F,510C
Vapor Pres:NOT GIVEN
Vapor Density:NOT GIVEN
Spec Gravity:2.5-2.9
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:NIL
Appearance and Odor:METALLIC APPEARENCE,, NO ODOR
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:USED OR UNUSED PRODUCT SHOULD BE TESTED TO
DETERMINE HAZARD STATUS AND DISPOSAL REQUIREMENTS UNDER FEDERAL,
STATE OR LOCAL REGULATIONS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:221VA IPSWITCH PINE
CAGE:EO256
CAGE:EO256
CAGE:0K1A4
============= Composition/Information on Ingredients =============
Ingred Name:C.I. PIGMENT RED 49 *96-2*
CAS:1103-38-4
Fraction by Wt: 0-1.04%
Ingred Name:SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC, HIGH FLASH
AROMATIC NAPHTHA, C8&10 AROMATIC HYDROCARBON *96-2*
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 0-3.5%
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED (C10-C15 SATURATED
HYDROCARBONS 97%, C10 AROMATICS 3%) (SUSP CARC IARC) * 96-2 *
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 0-9%
Other REC Limits:200 PPM EXXON
Ingred Name:HEAVY ALIPHATIC NAPHTHA *96-2*
CAS:64742-96-7
Fraction by Wt: 15-27%
Other REC Limits:100 PPM
Ingred Name:STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 7.5-13%
Other REC Limits:525 MG/CUM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 0-4%
OSHA PEL:2 MG/CUM (RESP DUST)
ACGIH TLV:2 MG/CUM (RESP DUST)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION. INGESTION:
HARMFUL/FATAL. CONTAINS MINERAL SPIRITS. DON'T TAKE INTERNALLY.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SKIN: WASH THOROUGHLY W/SOAP
& WATER. EYES: FLUSH THOROUGHLY W/WATER, THEN REMOVE ANY CONTACT
LENSES. CONTINUE TO FLUSH W/WATER FOR 15 MINS. INGESTION: DON'T
INDUCE VO MITING. OBTAIN MEDICAL ATTENTION IN ALLCASES.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:135F
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEMICAL/CO2.
Fire Fighting Procedures:DON'T USE DIRECT STREAM OF WATER. PRODUCT WILL
FLOAT & CAN BE REIGNITED ON SURFACE OF WATER. WEAR SCBA &
PROTECTIVE CLOTHING. USE WATER SPRAY TO COOL CONTAINERS
Unusual Fire/Explosion Hazard:COMBUSTIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: ABSORB W/SAND/OTHER SUITABLE ABSORBENT
MATERIAL & PLACE IN CONTAINER FOR DISPOSAL. LARGE: MAY BE SLIPPERY,
DIKE W/ABSORBENT MATERIAL. TRANSFER LIQUIDS & CONTAMINATED DIKING
MATERIAL TO SEPARATE , SUITABLE CONTAINERS FOR RECOVERY/DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T USE/STORE NEAR HEAT & OTHER
IGNITION SOURCES. CLOSE CONTAINERS AFTER EACH USE.
Other Precautions:DON'T TAKE INTERNALLY. AVOID CONTACT W/SKIN & EYES.
AVOID INHALATION & USE ONLY W/ADEQUATE VENTILATION. IF USING
INDOORS, OPEN ALL WINDOWS & DOORS TO MAKE SURE THERE IS FRESH AIR
MOVEMENT. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ADEQUATE VENTILATION CAN'T BE MAINTAINED,
WEAR RESPIRATORY PROTECTION.
Ventilation:IF USING INDOORS, OPEN ALL DOORS TO MAKE SURE THERE IS
FRESH AIR MOVEMENTS.
Supplemental Safety and Health
APPEARANCE: CLEAR AMBER TO OPAQUE EARTH-TONE, SLIGHTLY VISCOUS LIQUID
W/MILD HYDROCARBON ODOR.
================== Physical/Chemical Properties ==================
Spec Gravity:0.917-0.946
Solubility in Water:INSOLUBLE
Appearance and Odor:(SEE SUPP)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME & OTHER IGNITION
SOURCES.
Hazardous Decomposition Products:THERMAL: HYDROCARBON FUMES, SMOKE, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:POURABLE INSULATION, 5253
Preparer's Name:A G NIGHSWANDER
CAGE:PREMI
CAGE:3376X
CAGE:PREMI
============= Composition/Information on Ingredients =============
Ingred Name:PERLITE (MFR INVALID CAS#: SEQ-25-3)
CAS:93763-70-3
RTECS #:SD5254000
Fraction by Wt: 1-25%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:PORTLAND CEMENT; (CEMENT)
CAS:65997-15-1
RTECS #:VV8770000
Fraction by Wt: 25-50%
OSHA PEL:50 MPPCF; Z-3
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CLAY (KAOLIN); (CLAY)
CAS:1332-58-7
RTECS #:GF1670500
Fraction by Wt: 1-25%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 1-25%
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:SILICA, AMORPHOUS - DIATOMACEOUS EARTH;(DIATOMACEOUS
EARTH).
CAS:61790-53-2
RTECS #:VV7311000
Fraction by Wt: 1-10%
OSHA PEL:20 MPPCF; Z-3
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:SUPP DATA: USED FOR DUST LEVELS ABOVE 0.05 MG/M3 RESP
CRYSTALLINE SILICA. 3) DUST GENERATION SHOULD BE MINIMIZED(ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: BY USE OF DUST CONTROL EQUIPMENT/WATER SPRAY. 4)
WEAR PROT CLTHG & VACUUM CLEAN PRIOR TO REMOVING CLTHG.(ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: 5) WHERE THERE IS A POSS OF EXPOS TO DUST CONTAINING
CRYSTALLINE SILICA, THE FOLLOWING WARNING SHOULD BE(ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: POSTED: FREE SILICA WORK AREA/AVOID BREATHING
DUST/DUST MAY CAUSE DELAYED LUNG INJURY (SILICOSIS).
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:CEMENT COMPONENT IN PROD IS CAUSTIC TO
EYES & CAN CAUSE IRRIT TO SKIN ON RPTD/PRLNGD CONT. DUST FROM PROD
CONTAINS CRYSTALLINE SILICA & A DUST MASK MUST BE USED WHERE TLV IS
EXCEEDED. ACUTE: INHAL: TR ANSITORY UPPER RESP PHYSICAL IRRIT.
MAYCAUSE UPPER RESP IRRIT FROM DEHYDRATION ACTION OF CEMENT ON
MUC(EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ: IARC
MONOGRAPHS, SUPPLEMENT. VOL 7, PG 341, 1987: GROUP 2A. NTP 7TH
ANNUAL REPORT ON(SUPDAT)
Effects of Overexposure:HLTH HAZ: MEMBS. SKIN: IRRIT FROM RPTED/PRLNGD
CONTACT. EYE: CAUSTIC IRRIT & INFLAMM. CHRONIC: EXCESS INHAL ABOVE
PEL OF CRYSTALLINE SILICA (FREE SILICA) OVER LONG PERIODS OF TIME
MAY CAUSE DISABLING LUNG DISEASE (SILICOSIS) WHICH REDUCES BRTHG
CAPACITY & LEAD TO INCREASED SUSCEPTIBILITY TO OTHER LUNG DISEASE.
Medical Cond Aggravated by Exposure:PRE-EXISTING CHRONIC LUNG
CONDITIONS SUCH AS, BUT NOT LIMITED TO, BRONCHITIS, EMPHYSEMA &
ASTHMA.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH THORO W/WATER FOR AT LEAST 15 MINUTES. IF IRRIT
PRESISTS, SEEK MED ATTN. SKIN: WASH W/MILD SOAP & WATER. INHAL:
REMOVE TO FRESH AIR. INGEST: CALL MD IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:THIS PRODUCT IS NON-COMBUST REFRACTORY. USE
EXTINGUISHING MEDIA APPROP TO THE SURROUNDING AREA.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:CAREFULLY SCOOP UP MATL INTO SUITABLE CNTNR.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN DRY AREA. THIS PRODUCT
CONTAINS CEMENT, WHICH WILL RESULT IN PREMATURE CONSOLIDATION IF
EXPOSED TO MOISTURE DURING STORAGE.
Other Precautions:BECAUSE OF POSS PRESENCE OF CRYSTALLINE SILICA IN
USED REFRACTORY DEBRIS, PARTICULAR CARE SHOULD BE EXERCISED DURING
TEAR-OUT TO MINIMIZE GENERATION OF DUST. ADHERENCE TO PROPER
METHODS OF DUST SUPPRE SSION & CONTROL IS IMPERATIVE.(SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN. NIOSH/MSHA APPROVED RESPIRATORS I/A/W
29CFR 1910.134 FOR DUST LEVELS >0.05 MG/M3 RESP CRYSTALLINE SILICA.
Ventilation:PROVIDE ADEQ GENL VENT & LOC VENT TO CONTROL MIST &/DUST
LEVELS TO NO MORE THAN TLV.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA. LONG SLEEVE CLOTHING IS RECOMMENDED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PH: 10.5(10% AQUEOUS SLURRY). EXPLAN OF CARCIN: CARCINOGENS, 1994:
ANTICIPATED TO BE CARCINOGEN. OTHER PREC: FOLLOWING ARE RECOMM
PRECS TO BE TAKEN DURING REMOVAL: 1) EMPLOYEES SHOULD BE APPRISED
OF H AZARDS & PROPER CNDTNS & PRECS FOR SAFEUSE/EXPOS. 2) APPRVD
RESPS, I/A/W REQS OF 29 CFR 1910.134, SHOULD BE(ING 6)
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:>2250F,>123
Spec Gravity:0.5-0.6(H*2O=1)
pH:SUPDAT
Solubility in Water:SLIGHT
Appearance and Odor:LIGHT BROWN, GRANULAR TO FINE MATERIAL W/NO
DETECTABLE ODOR.
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONTAINS CEMENT SO MOISTURE CAN CAUSE PREMATURE CONSOLIDATION.
Stability Condition to Avoid:THIS MATERIAL IS STABLE UNDER NORAM
CONDITIONS OF DRY STORAGE.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL: PRODUCT IS NON-BIODEGRADABLE & DOES
NOT POSSES CHARACTERISTICS OF A HAZARDOUS WASTE PER EPA TCLP
METHOD. DISPOSE OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SPARVAR FLUORESCENT SPRAY PAINT (SUP DATA)
CAGE:HO600
CAGE:86142
CAGE:HO600
============= Composition/Information on Ingredients =============
Ingred Name:HEXANE (N-HEXANE)
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: 18%
Other REC Limits:N/K
OSHA PEL:500 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 12%
Other REC Limits:N/K
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VM&P NAPHTHA (LIGROINE)
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 8%
Other REC Limits:N/K
OSHA PEL:300 PPM/400 STEL
ACGIH TLV:300 PPM; 9192
Ingred Name:N-HEPTANE
CAS:142-82-5
RTECS #:MI7700000
Fraction by Wt: 17%
Other REC Limits:N/K
OSHA PEL:500 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9293
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 12.0%
Other REC Limits:N/K
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9192
Ingred Name:ISOBUTANE
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 16%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TOLUENE:OVEREXPOS:POSS LIVER,KIDNEY
DMG.ASPHYXIATION.REPORTS HAVE ASSOC RPTD/PRLNG OVEREXPOS W/
PERMANENT BRAIN & NERV SYS DMG.DELIB CONCENTRATING & INHAL MAY BE
ADDICTING & POSS FATAL.HEXANE:CHRONIC EXPOS:PERIPHERAL
NEUROPATHY.PROPANE:ASPHYXIANT.HEPTANE:ASPHYXIATION.VM & P
NAPHTHA:ASPHYXIATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:IRRIT.SKIN:IRRIT.ABSORPTION:NO HAZ KNOWN
TO BORDEN.INGEST:POSS HARMFUL.LIQ OR VAP CAN CAUSE IRRIT OF
THROAT.INHAL:POSS HARMFUL.LIQ OR VAP CAN CAUSE IRRIT OF NOSE,THROAT
& LUNGS.CNS DEPRESSION (HD
CH,DIZZ,NAUS,VOMIT,DROW,UNCON,ASPHYXIATION).CHRONIC EXPOSURES HAVE
CAUSED PERIPHERAL NEUROPATHY.CYANOSIS,RESP DISTRESS.
Medical Cond Aggravated by Exposure:N/K
======================= First Aid Measures =======================
First Aid:EYES:IMMED FLUSH W/ PLENTY OF WATER FOR AT LEAST 15
MIN,HOLDING LIDS APART.CALL MD.SKIN:FLUSH W/ WATER.IF IRRIT
PERSISTS,CALL MD.INGESTION:DO NOT INDUCE VOMITING.CALL MD
IMMED.INHALATION:REMOVE TO FRE SH AIR.IF NOT BREATHING,GIVE
ARTIFICIALRESPIRATION,PREFERABLY MOUTH-TO-MOUTH.IF BREATHING IS
DIFFICULT,GIVE OXYGEN.CALL MD.
===================== Fire Fighting Measures =====================
Flash Point:N/K
Lower Limits:N/K
Upper Limits:N/K
Extinguishing Media:DRY CHEMICAL,FOAM OR CO*2.WATER MAY BE
INEFFECTIVE,BUT SHOULD BE USED TO COOL FIRE-EXPOSED CONTRS.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:EXTREMELY FLAM.CONTENTS UNDER PRESS:MAY
BURST IF EXPOSED TO HIGH TEMP.AVOID RADIATORS,STOVES,DIRECT
SUN,OTHER HEAT SOURCES.DO NOT PUNCTURE/INCIN CONTR.(SEE SUP)
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES.SOAK UP WITH
ABSORBENT MATERIAL AND REMOVE TO A CHEMICAL DISPOSAL AREA.PREVENT
ENTRY INTO NATURAL BODIES OF WATER.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE OVER 120F,49C.HANDLE IAW
GOOD INDUS HYGIENE & SFTY PRACTICES (INCLUDING AVOIDING UNNEC EXPOS
& REMOVAL OF MATL FROM EYES,SKIN & CLTHG).
Other Precautions:TO MINIMIZE EMPLOYEE EXPOS USE:LOCAL EXHAUST
VENT,ENCLOSED SYS DESIGN,PROCESS ISOLATION & REMOTE CONTROL IN
COMBINATION W/ APPROP PERSONAL PROT EQUIP & PRUDENT WORK
PRACTICES.RECOM CONSULTATION W/ EXP ERTS TO DETERMINE IF PROGRAM IS
ADEQ.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Other Protective Equipment:N/K
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
PART NO:S-311,S-312.% VOLATILES BY WT:83,% NONVOLATILES BY WT:17.EXPLO
HAZ:DO NOT SPRAY NEAR OPEN FLAME.MAJOR DECOMP
PRODUCTS:CO,CO*2.ROUTES OF ENTRY:INGEST/INHAL/SKIN:.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:50 PSIG
Vapor Density:>1 (AIR=1)
Spec Gravity:<1 (WATER=1)
Evaporation Rate & Reference:FASTER THAN BUTYL ACETATE
Solubility in Water:SLIGHT
Appearance and Odor:AEROSOL PAINT.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
N/K
Stability Condition to Avoid:NORMALLY STABLE AS DEFINED IN NFPA
704-12(4-3.1).
Hazardous Decomposition Products:MAJOR DECOMPOSITION PRODUCTS:CO,CO*2.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .EMPTY CONTAINER MAY CONTAIN
EXPLOSIVE VAPORS.DO NOT CUT,PUNCTURE OR WELD ON OR
NEARBY.INCINERATION WILL CAUSE CONTAINER T O BURST VIOLENTLY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DEKACHROME DEVELOPER, PART A
Kit Part:Y
CAGE:64145
CAGE:64145
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM SULFITE
CAS:10117-38-1
Fraction by Wt: 10-15%
Ingred Name:POTASSIUM METABORATE
CAS:13709-94-9
Fraction by Wt: 1-5%
OSHA PEL:1 MG/M3 BORATE
ACGIH TLV:1 MG/M3 BORATE
Ingred Name:BORIC ACID
CAS:10043-35-3
RTECS #:ED4550000
Fraction by Wt: 1-5%
OSHA PEL:10 MG BORATES/M3
ACGIH TLV:5 MG BORATES/M3
Ingred Name:ASCORBIC ACID ADDUCT
CAS:50-81-7
RTECS #:CI7650000
Fraction by Wt: 1-5%
OSHA PEL:NOT EXTABLISHED
Ingred Name:POTASSIUM BROMIDE
CAS:7758-02-3
RTECS #:TS7650000
Fraction by Wt: 0.1-1.0%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 75-80%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT MAY CAUSE EYE, SKIN &
RESPIRATORY OR G/I TRACT IRRITATION. IT IS CONSIDERED A LOW HAZARD
FOR NORMAL INDUSTRIAL HANDLING.
Explanation of Carcinogenicity:PRODUCT CONTAINS NO INGREDIENTS LISTED
AS CARCINOGENS BY NTP, IARC, OSHA, OR ACGIH.
Effects of Overexposure:EYE:CAUSES IRRITATION SKIN:CAUSES IRRITATION,
AND MAY SENSITIZE AN ALLERGIC REACTION. INHALED:UNLIKELY
EXPOSURE,MAY CAUSE IRRITATION. INGESTED:MAY BE HARMFUL IF
SWALLOWED. HMIS:MAY CAUSE G/I IRRITA TION,NAUSEA,VOMITING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH WITH WATER 15 MIN.SKIN:REMOVE CONTAMINATED
CLOTHING AND LAUNDER BEFORE REUSE. WASH SKIN WITH SOAP AND WATER.
INHALED: REMOVE TO FRESH AIR. INGESTED:IF CONSCIOUS,GIVE 1-2
GLASSES OF WATE R AND IMMEDIATELY INDUCE VOMITING. (NOTHING BY
MOUTH IF UNCONSCIOUS.) GET IMMEDIATE MEDICAL CARE. IF ANY
IRRITATION PERSISTS OR IS SEVERE, GET MEDICAL CARE.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:USE MEDIA APPROPRIATE FOR SOURCE OF FIRE.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER AS LIQUID OR MOP UP WITH
CLOTH,PAPER,ETC.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY,WELL VENTILATED
AREA. KEEP TIGHTLY CLOSED WHEN NOT IN USE. KEEP AWAY FROM STRONG
ACIDS.
Other Precautions:READ LABEL AND FOLLOW DIRECTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. USE NIOSH/MSHA APPROVED
RESPIRATOR IF PEL/TLV IS EXCEEDED OR DISCOMFORT IS EXPERIENCED.
Ventilation:NORMAL ROOM VENTILATION SUPPLEMENTED WITH LOCAL EXHAUST
ESPECIALLY WHEN MIXING.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER. USE APRON
AND FACE SHIELD WHEN POURING LIQUIDS OR IF SPLASHING IS LIKELY.
Work Hygienic Practices:USE GOOD CHEMICAL HYGIENE PRACTICE. AVOID
UNNECESSARY CONTACT.
Supplemental Safety and Health
PART A OF A 2 PART PRODUCT. ILFORD STOCK NUMBER OP9973975, 2.5 GALLON.
COD = 50 GM OXYGEN/L. ALSO SEE ADD.DATA.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:<32F,<0C
Vapor Pres:AS WATER
Vapor Density:AS WATER
Spec Gravity:1.244
pH:9.8
Evaporation Rate & Reference:AS WATER
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR COLORLESS LIQUID, NO ODOR
Percent Volatiles by Volume:75
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MINERAL ACIDS
Stability Condition to Avoid:NO INFORMATION GIVEN BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
SULFUR DIOXIDE, NITROGEN OXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W FEDERAL,STATE,LOCAL REGULATIONS.
MFR SUGGESTS FLUSH TO ACID-FREE SEWER IF PERMITTED.
| 1 | eyes_protection_mandatory |
Subsets and Splits
No saved queries yet
Save your SQL queries to embed, download, and access them later. Queries will appear here once saved.