text
stringlengths 595
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:LAGGING ADHESIVE AND COATING, 713, WHITE &
Preparer's Name:JOHN TIDQUIST
CAGE:14947
CAGE:14947
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA III) (VAPOR PRESSURE .10 MM HG @ 68
F)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: <2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:50 PPM
ACGIH TLV:50 PPM CEILING
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CHLORINATED PARAFFIN
CAS:63449-39-8
RTECS #:RV0480000
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
Ingred Name:VINYLACETATE-DIBUTYLMALEATE
CAS:25035-90-9
Fraction by Wt: 10-15%
Other REC Limits:NONE SPECIFIED
Ingred Name:HEXYLENE GLYCOL (VAPOR PRESSURE .05 MM HG @ 68 F)
CAS:107-41-5
RTECS #:SA0810000
Fraction by Wt: 0.5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:25 PPM
ACGIH TLV:25 PPM CEILING
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION. EYE: IRRITATION.
TEARING, STINGING, REDNESS. INHALATION: COUGHING, SORENESS IN
RESPIRATORY TRACT, CHEST TIGHTNESS, DIFFICULT BREATHING, NASAL &
RESPIRATORY IRRITATION. INGESTION: DRU NKENNESS, RAPIDLY PASSING
INTO COMA, WITH SERIOUS KIDNEY INJURY &/OR DEATH. CAN IRRITATE
MUCOUS MEMBRANES, NARCOSIS.
Explanation of Carcinogenicity:VINYL ACETATE HAS BEEN REPORTED TO CAUSE
CANCER IN LABORATORY ANIMALS.
Effects of Overexposure:TARGET ORGAN: LIVER.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING LUNG
DISORDERS MAY BE MORE SUSCEPTIBLE.
======================= First Aid Measures =======================
First Aid:SKIN: WASH WITH SOAP & WATER. EYES: FLUSH WITH CLEAN WATER 15
MINUTES. IF IRRITATION PERSISTS, CONSULT PHYSICIAN. INHALATION:
REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT, ADMINISTER OXYGEN.
IF IRRI TATION PERSISTS, CONSULT PHYSICIAN. INGESTION: GIVE 2
GLASSES OF WATER, INDUCE VOMITING, CONSULT PHYSICIAN OR POISON
CONTROL CENTER. NEVER GIVE ANYTHING BY MOUTH TO UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE TO BOIL
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:PRODUCT WILL NOT BURN UNTIL AFTER WATER HAS
BOILED OR EVAPORATED. FOR DRIED FILM OR RESIDUAL SOLIDS, FULL
PROTECTION EQUIPMENT IS RECOMMENDED, INCLUDING SCBA.
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA. CONTAIN & ABSORB LIQUID W/INERT
MAT'L, THEN SHOVEL INTO CONTAINER. PREVENT PRODUCT FROM ENTERING
STREAMS OR DRINKING WATER SUPPLIES. BEFORE DRYING, PRODUCT MAY BE
WASH AWAY W/WATER; AFTER D RYING, REMOVE W/PAINT SCRAPER OR
STRONGSOLVENT.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING VAPORS AND APPLICATION
TO HOT SURFACES, AS VAPOR MAY BE IRRITATING. KEEP CONTAINER CLOSED.
USE WITH ADEQUATE VENTILATION.
Other Precautions:STORE INDOORS AT TEMPERATURES OF 45-90F. FOR
INDUSTRY/PROFESSIONAL USE ONLY. NOT INTENDED FOR RETAIL SALE OR USE
BY INDIVIDUAL CONSUMERS. DO NOT REUSE CONTAINER FOR POTABLES OR
EDIBLES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESTRICTED VENT AREAS: USE APPROVED CHEMICAL
VAPOR RESPIRATOR. WHERE MISTS OR SPRAY MAY BE GENERATED, AVOID
INHALATION OF AIRBORNE PARTICULATES BY USING AN APPROVED RESPIRATOR
W/ORGANIC VAPOR CARTRIDG E W/PREFILTER FOR MIST/DUST.
Ventilation:GENERAL (MECHANICAL) ROOM VENTILATION WITH LOCAL EXHAUST.
Work Hygienic Practices:THOROUGHLY CLEASE HANDS AFTER HANDLING. LAUNDER
CONTAMINATED CLOTHNG BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:25.0F,-3.9C
Decomp Temp:Decomp Text:240F,116C
Vapor Density:< AIR
Spec Gravity:1.29
pH:8-9
Viscosity:75000 CP
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:APPRECIABLE
Appearance and Odor:VISCOUS, WHITE OR RED PASTE WITH MILD LATEX ODOR.
Percent Volatiles by Volume:60
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MATERIALS INCOMPATIBLE WITH WATER.
Hazardous Decomposition Products:THERMAL DECOMPOSITION WILL YIELD CO,
CO2, HCL, ANTIMONY-OXYCHLORIDE AND FRAGMENTED SHORT-CHAIN
HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE WITH ALL APPLICABLE REGULATIONS.
REVIEW HAZARD SECTION OF MSDS BEFORE ATTEMPTING CLEANUP. EMPTY
CONTAINERS ARE NON-HAZARDOUS UNDER RCRA AS INDUSTRIAL WASTE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TRIBOLUBE
CAGE:66164
CAGE:66164
============= Composition/Information on Ingredients =============
Ingred Name:PERFLUORINATED POLYETHER
Ingred Name:MOLYBDENUM DISULFIDE
CAS:1317-33-5
RTECS #:QA4697000
OSHA PEL:10 MG/M3 TDUST (MO)
ACGIH TLV:10 MG/M3 (MO); 8990
===================== Hazards Identification =====================
Routes of Entry: Inhalation:UNKNOWN Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:NO DATA AVAILABLE;MAY IRRITATE EYES
AND SKIN.
Effects of Overexposure:NO DATA AVAILABLE:MAY IRRITATE EYES & SKIN.
Medical Cond Aggravated by Exposure:NO DATA AVAILABLE.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH PLENTY OF WATER. SKIN:CLEAN AND WASH WITH
SOAP & WATER. INGESTION:CONSULT A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NONE NOTED:USE SUITABLE MEDIA FOR SURROUNDING FIRE.
Fire Fighting Procedures:KEEP CONTAINER CLOSED AND KEEP COOL BY
SPRAYING WATER WHEN EXPOSED TO FIRE.USE NIOSH/MSHA APPROVED SCBA IN
AN ENCLOSED AREA.
Unusual Fire/Explosion Hazard:THIS PRODUCT DOES NOT BURN,BUT WILL
THERMALLY DECOMPOSE ABOVE 290C.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION.USE SUITABLE
INERT ABSORBENT MATERIAL AND RECOVER FOR PROPER DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL DRY AND WELL VENTILATED
AREA.KEEP AWAY FROM HEAT AND OPEN FLAME,EXPLOSIVE MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NEEDED IN CASE OF AN ADEQUATE VENTILATION.
Ventilation:GENERAL TO MAINTAIN AN ADEQUATE VENTILATION.
Other Protective Equipment:FULL SKIN AND EYES PROTECTION;EYE-WASH.
Work Hygienic Practices:AVOID CONTACT WITH EYES AND SKIN.WASH
THOROUGHLY AFTER EACH USE.DO NOT SMOKE,EAT AND DRINK IN WORK AREA.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V6
Vapor Pres:0.01
Spec Gravity:1.9
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE,BUTTERY GREASE,NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MOLTEN ALKALI METALS,INTERHALOGEN COMPOUNDS,STRONG,NON-AQUOUS ALKALI
AND LEWIS ACID ABOVE 100C.
Stability Condition to Avoid:AVOID HEATING ABOVE 250C.
Hazardous Decomposition Products:HF COF*2,PERFLUOROCARBON OLEFINS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF COLLECTED MATERIAL IN ACCORDANCE WITH
LOCAL,STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FA1483A
CAGE:JO764
CAGE:81831
CAGE:JO764
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR.AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UNC ONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:903-MOISTURE & CORROSION PREVENTER
CAGE:IO163
CAGE:IO163
CAGE:BUCHD
============= Composition/Information on Ingredients =============
Ingred Name:CARBON DIOXIDE (PROPELLANT). OSHA PEL:10000 PPM; 30000 PPM
STEL. ACGIH TLV:5000 PPM;30000 PPM STEL.
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: 1-5%
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM/30000STEL;93
Ingred Name:ETHANE,1,1,1-TRICHLORO-; (1,1,1-TRICHLOROETHANE)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 20-50%
OSHA PEL:350 PPM;450 PPM STEL
ACGIH TLV:350 PPM;450 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:METHANE, DICHLORO-; (DICHLOROMETHANE)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 20-50%
OSHA PEL:1000 PPM,C
ACGIH TLV:50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED;(PETROLEUM DISTILLATE)
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 5-10%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE TRANSIENT IRRITATION OF
EYES. MILDLY IRRITATING TO SKIN UPON PROLONGED CONTACT. INHALATION
OF PRODUCT IS A CENTRAL NERVOUS SYSTEM DEPRESSANT. ANESTHETIC
EFFECTS MAY OCCUR IN 1000 PPM RANGE. MAY INCREASE MYOCARDIAL
IRRITABILITY. INGESTION MAY CAUSE GASTROINTESTINAL IRRITATION &
INHALATION (EFTS OF OVEREXP)
Explanation of Carcinogenicity:METHYLENE CHLORIDE:GROUP 2B (IARC);
ANTICIPATED TO BE A CARCINOGEN (NTP).
Effects of Overexposure:HLTH HAZ:EFFECTS. CHLOROCARBON MATLS HAVE
PRODUCED SENSIT OF MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS & COULD
HAVE A SIMILAR EFFECT IN HUMANS. ADRENOMIMETICS (E.G., EPINEPHRINE)
MAY BE CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINING USES IN HUMANS
ACUTELY/ CHRONICALLY EXPOSED TO CHLOROCARBONS .
Medical Cond Aggravated by Exposure:UNKNOWN.
======================= First Aid Measures =======================
First Aid:INGEST:DO NOT INDUCE VOMITING. CALL MD. INHAL:REMOVE TO FRESH
AIR. EYE:FLUSH WITH WATER FOR AT LEAST 15 MINUTES. CALL MD IF
IRRITATION. SKIN:WASH WITH SOAP & WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Lower Limits:13%
Upper Limits:23%
Extinguishing Media:DRY CHEMICAL, FOAM OR CO*2.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESS DEMAND SCBA &
FULL PROT EQUIP . KEEP CONTAINERS COOL. USE SHIELDING TO PROTECT
AGAINST BURSTING, RUPTURING/VENTING CNTNRS.
Unusual Fire/Explosion Hazard:AT ELEVATED TEMPERATURES (OVER 130F)
CONTAINERS MAY BURST, RUPTURE OR VENT. THERMAL DECOMPOSITION
PRODUCTS MAY INCLUDE HCL & PHOSGENE .
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF FLAME, SPARKS, OR HEAT.
PROVIDE ADEQUATE VENTILATION. WIPE UP SPILLS, THEN WASH WITH A
CLEANER TO REMOVE FINAL TRACES. FLOORS MAY BE SLIPPERY; USE CAUTION
TO AVOID FALLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTENTS UNDER PRESSURE. DO NOT STORE
WHERE TEMPERATURES MAY EXCEED 120F. VAPORS HARMFUL.
Other Precautions:READ ENTIRE LABEL BEFORE USING. KEEP OUT OF REACH OF
CHILDREN. NO SMOKING IN AREA OF USE. DO NOT USE IN THE GENERAL
VICINITY OF ARC WELDING/OPEN FLAMES OR HOT SURFS. HEAT AND/OR UV
RADIATION MAY CAUSE FORMATION OF HCL &/OR PHOSGENE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST:HOOD OR FAN. MECHANICAL:MAINTAIN ADEQUATE
VENTILATION.
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:NOT APPLICABLE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:104F,40C
Vapor Pres:217
Vapor Density:>1
Spec Gravity:1.17
Evaporation Rate & Reference:>1 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, THIN BROWN LIQUID HAVING A CHLORINATED
HYDORCARBON ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:AVOID HEATING TO ABNORMAL TEMPERATURES.
Hazardous Decomposition Products:HCL, OXIDES OF CARBON AND MINUTE
TRACTS OF PHOSGENE AND CHLORINE FORMED UPON COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT PUNCTURE OR INCINERATE CONTAINERS.
REPLACE CAP AND DISCARD CONTAINER IN TRASH.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LITHIUM SULFUR DIOXIDE BATTERY, BA-5567/U
CAGE:0E1R2
CAGE:0E1R2
============= Composition/Information on Ingredients =============
Ingred Name:LITHIUM METAL
CAS:7439-93-2
RTECS #:OJ5540000
Fraction by Wt: 2.3%
Other REC Limits:NONE SPECIFIED
Ingred Name:SULFUR DIOXIDE (SARA III)
CAS:7446-09-5
RTECS #:WS4550000
Fraction by Wt: 22%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 PPM/5 STEL
ACGIH TLV:2 PPM/5 STEL; 9293
Ingred Name:ACETONITRILE (SARA III)
CAS:75-05-8
RTECS #:AL7700000
Fraction by Wt: 7.7%
Other REC Limits:NONE SPECIFIED
OSHA PEL:40PPM/60 STEL
ACGIH TLV:40PPM/60STEL; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: 10-20 PPM IRRITATING; 100 PPM
DANGEROUS; ABOVE 400 PPM LIFE THREATENING. CHRONIC: RHINITIS.
Explanation of Carcinogenicity:NONE OF THE HAZARDOUS INGREDIENTS ARE
LISTED AS CARCINOGENIC TO HUMANS BY IARC, NTP OR OSHA.
Effects of Overexposure:EYE AND RESPIRATORY IRRITATION, DRY THROAT AND
COUGHING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:FOR SULFUR DIOXIDE EXPOSURE; REMOVE TO VENTILATED AREA.
CONSULT PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOR BURNING BATTERIES USE CLASS D EXTINGUISHERS;
LITH-X, POWDERED GRAPHITE; MET-L-X.
Fire Fighting Procedures:USE WATER SPRAY OR CARBON DIOXIDE TO LOWER
TEMPERATURE & EXTINGUISH FIRES IN PACKING MATERIAL. USE SELF
CONTAINED BREATHING APPARATUS & FULL PROTECTIVE CLOTHING
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:VENTILATED AREAS EQUIPPED WITH
SPRINKLER SYSTEM, AWAY FROM FLAMMABLES.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FULL FACE CHEMICAL CARTRIDGE, BELOW 20 PPM. SELF
CONTAINED BREATHING APPARATUS.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NEEDED FOR RUPTURED BATTERIES ONLY - FOR
SULFUR DIOXIDE FIRE.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER USE AND BEFORE
EATING, DRINKING OR SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:Z6
Appearance and Odor:SOLID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
LITHIUM REACTS WITH WATER TO FORM HYDROGEN. MOIST SULFUR DIOXIDE IS
CORROSIVE.
Stability Condition to Avoid:LITHIUM REACTS WITH AIR, WATER AND MOST
MATERIALS.
Hazardous Decomposition Products:RUPTURED BATTERIES WILL RELEASE SULFUR
DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:ACCORDING TO REGULATIONS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:159 8663 AQUA-IMAGE DELETION PEN, BROAD, BOX OF 12
CAGE:EO271
CAGE:19139
CAGE:EO271
============= Composition/Information on Ingredients =============
Ingred Name:TETRAHYDROFURAN (CERCLA)
CAS:109-99-9
RTECS #:LU5950000
Fraction by Wt: 45-50%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM
ACGIH TLV:200 PPM/250STEL;9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 20-25%
Other REC Limits:NONE RECOMMENDED
Ingred Name:BENZYL ALCOHOL
CAS:100-51-6
RTECS #:DN3150000
Fraction by Wt: 15-20%
Other REC Limits:NONE RECOMMENDED
Ingred Name:HYDROGEN FLUORIDE (SARA 302/313) (CERCLA)
CAS:7664-39-3
RTECS #:MW7875000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3 PPM (F)
ACGIH TLV:C 3 PPM(F); 9495
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:EXPECTED TO BE LOW HAZARD FOR
RECOMMENDED HANDLING. EYES:CAUSES IRRIT. SKIN:CAUSES IRRIT.
INGEST:EXPECTED TO BE LOW INGEST HAZARD.
Explanation of Carcinogenicity:PER MSDS:CARCINOGENICITY
CLASSIFICIATIN:IARC/ACGIH/NTP/OSHA:NONE.
Effects of Overexposure:EYE/SKIN IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:IF SYMTOMATIC MOVE TO FRESH AIR.GET MED ATTN IF
SYPMTOMS PERSIST. EYE:IMMED FLUSH W/PLENTY OF WATER FOR @LEAST
15MINS.GET MED ATTN. SKIN:IMMED FLUSH W/PLENTY OF WATER FOR @LEAST
15MINS.GET MED A TTN IF SYMPTOMS OCCUR. INGEST:DRINK 1-2GLASSES OF
WATER.SEEK MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:<100F,<38C
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE (CO2), DRY CHEMICAL.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOHTING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE, BASED ON LIMITED QUANTITY OF FLUID
CONTAINED IN PEN. HOWEVER, COMPONENT IS EXTREMELY FLAMMABLE;FORM
SEXPLO PEROXIDES ON CONCENTRATION.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT W/EYES/SKIN/CLOTHING.USE
W/ADEQUATE VENTILATION.KEEP FROM CONTACT W/OXIDIZING MATLS.KEEP
CNTNR CLOSED.
Other Precautions:NONE SPECIFIED BY MANUFACTURER. MATERIAL HAS NOT BEEN
TESTED FOR ENVIRONMENTAL EFFECTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10AIR CHANGES/HR)
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS.
Other Protective Equipment:EYE BATH, WASHING FACILITIES, SAFETY SHOWER.
Work Hygienic Practices:WASH THOROUGHLY AFT HNDLG.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:147F,64C
Vapor Pres:86MM
Vapor Density:2.5
Spec Gravity:1.01
pH:N/AVAI
Evaporation Rate & Reference:47.6%,(N-BUTYL ACETATE=1)
Solubility in Water:SLIGHT-MODERATE
Appearance and Odor:LIQUID, COLORLESS, SLIGHT ODOR.
Percent Volatiles by Volume:47
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NON-HAZARDOUS, BASED ON LIMITED QUANTITY
OF FLUID CONTAINED IN PEN. HOWEVER, COMPONENET FORMS EXPLO
PEROXIDES ON CONCEN.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER. HAZ
COMBUST PROD:CARBON DIOXIDE, CARBON MONOXIDE, HYDROGEN FLUORIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:MAY BE DISPOSED OF W/GENERAL OFFICE WASTES.
DISCHARGE/TREATMENT/DISPOSAL MAY BE SUBJECT TO NAT/STATE/LOC LAWS.
CHEM SUBJ TO REPORTING REQMTS OF SEC 313,TITLE III SARA/49CFR PART
372:HYDROGEN FLUORIDE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:STAINLESS SILICONE LUBE TM-2383
CAGE:AERSL
CAGE:AERSL
============= Composition/Information on Ingredients =============
Ingred Name:HEXANE (N-HEXANE)
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: 28%
Other REC Limits:TRANS PEL: 500 PPM
OSHA PEL:500 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:METHYLENE CHLORIDE(SARA III)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 34%
OSHA PEL:500 PPM/C,1000; Z2
ACGIH TLV:50 PPM, A2; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 33%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9192
Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: 5%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE DIFFICULTY BRTHG,
DIZZ/NARCOSIS IN HIGH VAP CONC. WILL CAUSE DEFATTING/REDNESS OF
SKIN. EFTS ARE REVERSIBLE. LONG TERM EXPOS TO VAP MAY CAUSE
LUNG/LIVER/KIDNEY DMG. SOLVS LISTED HAVE BEEN RP TD TO AFFECT THE
CNS. INGESTION WILL RSLT IN VOMITING. METHYLENE CHLORIDE: WILL HAVE
AN EFFECT (SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:METHYLENE CHLORIDE: IARC-2B, NTP GROUP
2.
Effects of Overexposure:HLTH HAZ: ON THE CARDIO VASCULAR SYSTEM, INHAL
OF HIGH VAP CONC OVER LONG PERIODS OF TIME HAVE PRODUCED TUMORS IN
LAB ANIMALS. CHLOROCARBON/CHLOROFLUOROCARBON (CFC) MATLS HAVE
PRODUCED SENSITIZATION O F THE MYOCARDIUM TO EPINEPHRINE IN LAB
ANIMALS & COULD HAVE A SIMILAR EFFECT IN HUMANS. ADRENOMIMETICS
(SEE SUPP DATA)
Medical Cond Aggravated by Exposure:HEART DISEASE, RESPIRATORY
DISORDERS
======================= First Aid Measures =======================
First Aid:INHAL: GIVE OXYGEN. INGEST: DO NOT INDUCE VOMITING. GASTRIC
LAVAGE. EYES/SKIN: WASH WITH WATER FOR AT LEAST 15 MINUTES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-40F,-40C
Lower Limits:1.8
Upper Limits:12.0
Extinguishing Media:WATER FOG, DRY CHEMICAL, CARBON DIOXIDE
Fire Fighting Procedures:AEROSOL CANS MAY RUPTURE WHEN HEATED. WEAR
NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:HEATED CANS MAY BURST. THERMAL
DECOMPOSITION PRODUCTS MAY INCLUDE HCL AND PHOSGENE .
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT SWEEPING COMPOUND TO SOAK UP
MATERIAL. PUT INTO CONTAINER. DISPOSE AS HAZARDOUS WASTE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS, OR OPEN
FLAME. STORE AT TEMPERATURES BELOW 120F.
Other Precautions:NO SMOKING IN AREA OF USE. DO NOT USE IN THE GENERAL
VICINITY OF ARC WELDING, OPEN FLAMES OR HOT SURFACES. HEAT AND/OR
UV RADIATION MAY CAUSE THE FORMATION OF HCL AND/OR PHOSGENE .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED SCBA IF TLV LIMIT
EXCEEDED.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:LONG SLEEVES AND LONG PANTS
Work Hygienic Practices:DO NOT SMOKE WHILE USING. WASH HANDS AFTER USE.
Supplemental Safety and Health
EFTS OF OVEREXP: (E.G. EPINEPHRINE) MAY BE CONTRAINDICATED EXCEPT FOR
LIFE-SUSTAINING USES IN HUMANS ACUTELY OR CHRONICALLY EXPOSED TO
CHLOROCARBONS OR CFCS . RPTS HAVE ASSOC RPTD/PRLNG OCCUP OV EREXP
TO SOLVS WITH PERM BRAIN & NERV SYS DMG . MFR IDENTIFIES SKIN &
INGESTION AS ROUTES OF ENTRY.
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:-40F,-40C
Vapor Pres:50 PSIG
Vapor Density:4.0 (>AIR)
Spec Gravity:0.7
Evaporation Rate & Reference:>4 (BUTYL ACETATE=1)
Solubility in Water:NIL
Appearance and Odor:CLEAR/SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
METHYLENE CHLORIDE WILL REACT WITH ACTIVE METALS. SOLVENT INGREDIENTS
ARE INCOMPATIBLE WITH STRONG OXIDIZERS.
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:IN FIRE WILL DECOMPOSE TO WATER,
CARBON DIOXIDE, HALOGEN ACIDS AND PHOSGENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE AS HAZARDOUS WASTE IN ACCORDANCE WITH
EPA RCRA, FEDERAL, STATE AND LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:STARPOWER SUPER CLEANER/DEGREASER
Preparer's Name:BOBBY STOKES
CAGE:00ED3
CAGE:00ED3
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL MONOBUTYL ETHER
CAS:111-76-2
RTECS #:KJ8575000
OSHA PEL:240 MG/M3;50 PPM
ACGIH TLV:121 MG/M3;25 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:NONE
Effects of Overexposure:MIGHT IRRITATE EYES AND SKIN
======================= First Aid Measures =======================
First Aid:AVOID CONTACT WITH EYES. IF EYES COME IN CONTACT, RINSE
AFFECTED AREA WITH WATER. IF IRRITATION PERSISTS, CONSULT A
PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Extinguishing Media:NON-FLAMABLE. NO SPECIAL PROCEDURES REQUIRED.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:MOP UP AND RINSE AREA WITH WATER
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:KEEP OUT OF REACH OF CHILDREN. DO NOT TAKE
INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:NONE
Other Protective Equipment:NONE
Work Hygienic Practices:NORMAL GOOD HOUSEKEEPING.
Supplemental Safety and Health
HCC =V4 ASSIGNED BY DSCR-HMIS BASED UPON THE FLASH POINT OF ETHYLENE
GLYCOL MONOBUTYL ETHER, FLASH POINT = 142F (NOT GIVEN IN THE MSDS).
NON-BULK QUANTITIES ARE NOT REGULATED BY DOT.
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:=100.C, 212.F
Vapor Pres:6
Vapor Density:4.1
Spec Gravity:1
Evaporation Rate & Reference:0.1
Solubility in Water:INFINITE
Appearance and Odor:CLEAR LIQUID WITH WEAK ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
Conditions to Avoid Polymerization:WILL NOT OCCUR
==================== Disposal Considerations ====================
Waste Disposal Methods:RINSE CONTAINER AND DISCARD ACCORDING TO ANY
LOCAL, STATE, AND FEDERAL REGULATIONS.
===================== Regulatory Information =====================
SARA Title III Information:SECTION 311/312 HAZARD CATAGORIES: ACUTE
HEALTH, FIRE. SECTION 313 REPORTABLE INGREDIENTS: NONE.
Federal Regulatory Information:TSCA: THE INGREDIENTS OF THIS PRODUCT
ARE LISTED ON THE TSCA INVENTORY. CERCLA: THIS PRODUCT CONTAINS NO
CERCLA REPORTABLE MATERIALS. CONTACT LOCAL AUTHORITIES TO DETERMINE
IF THERE MAY BE OTHER LOCAL REPORTING REQUIREMENTS.
State Regulatory Information:NEW JERSEY-RIGHT-TO-KNOW INFORMATION: THIS
PRODUCT CONTAINS LIGHT ALIPHATIC PETROLEUM NAPHTHA (CAS#
64742-89-8), METHYL PROPYL KETONE (CAS# 107-87-9) AND HEPTANE (CAS#
142-822-5). CALIFORNIA PROPOSITI ON 65 INFORMATION: THIS PRODUCT
DOES NOT CONTAIN ANY CHEMICALS RECOGNIZED BY THE STATE OF
CALIFORNIA TO CAUSE CANCER AND/OR BIRTH DEFECTS OR REPRODUCTIVE
HARM. SCAQMD INFORMATION: IS THERE PHOTOCHEMIC ALLY REACTIVE
MATERIAL PRESENT? YES; WHAT % PHOTOCHEMICALLY REACTIVE MATERIAL?
50%; WHAT IS THE VOC CONTENT? 780 G/L; WHAT IS THE VAPOR PRESSURE
OF VOC'S? 30 MM HG @ 20C.
======================= Other Information =======================
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:ROYCO 363B
CAGE:07950
CAGE:07950
============= Composition/Information on Ingredients =============
Ingred Name:HYDROTREATED LIGHT NAPHTHENIC DISTILLATE PETROLEUM.
CAS:64742-53-6
RTECS #:PY8036000
Fraction by Wt: >97%
Ingred Name:OTHER COMPONENT
RTECS #:9999999ZZ
Fraction by Wt: <3%
===================== Hazards Identification =====================
Effects of Overexposure:EYES:IRRITATING.SKIN:CAUSE VARIOUS
DISORDER,DERMATITIS.INGEST:LOW TOXICITY,CATHARSIS,DIARRHEA.
======================= First Aid Measures =======================
First Aid:SKIN:WASH W.SOAP & H*2O. EYES:FLUSH W. H*2O. INGESTED:DON'T
INDUCE VOMITING. INHALED:REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF
NEED. KEEP WARM & QUIET. REMOVE CONTAMINATED CLOTHING. NEVER GIVE
ANYTHING BY MOUTH TO UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:330F/165.5C(COC)
Extinguishing Media:CO*2, FOAM, DRY CHEM.
Fire Fighting Procedures:WEAR SELF-CNTD BRTHG,APP H*20 SPRAY TO COOL
CONTR.
================== Accidental Release Measures ==================
Spill Release Procedures:TAKE UP W/DIATOMACEOUS EARTH,CLAY OR OTHER
INERT ABSORBENT & PLACE IN CONTAINER FOR LATER DISPOSA.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY PLACE W/ADEQUATE
VENTILATION
Other Precautions:MINIMIZE SKIN CONTACT
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL REQMNTS UNDER ORDINARY
CONDITIONS/ADEQUATE VENT.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:AS NEEDED
Supplemental Safety and Health
WHEN MATL USED UNDER HIGH PRESS.IT IS POSSIBLE FOR OIL(MATL) TO INJECT
INTO SKIN;GET PROMPT MEDICAL ATTN TO PREVENT SERIOUS DAMAGE. MSDS
DATED 11-1-85.
================== Physical/Chemical Properties ==================
HCC:V6
Spec Gravity:0.87
Solubility in Water:INSOLUBLE
Appearance and Odor:TAN COLORED MILD BLAND PETROLEUM ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, FLAMES
Hazardous Decomposition Products:CO,UNKNOWN ORGAN COMP.MAY BE FORMED IF
MATL UNDERGO PYROLYSI
==================== Disposal Considerations ====================
Waste Disposal Methods:IN COMPLIANCE W/LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SODIUM CARBONATE MONO-HYDRATE
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM CARBONATE MONOHYDRATE
CAS:497-19-8
RTECS #:VZ4050000
Fraction by Wt: 100%
===================== Hazards Identification =====================
Effects of Overexposure:DIRECT EYE CONTACT MAY CAUSE IRRITATION. PRLNG
SKIN CONTACT MAY CAUSE IRRIT.
======================= First Aid Measures =======================
First Aid:IN CASE OF SKIN OR EYE CONTACT, FLUSH W/PLENTY OF WATER; FOR
EYE CONTACT, GET ADDITIONAL MEDICAL ATTN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP & DISCARD.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE W/ ACIDS
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF NEC, NIOSH/MSHA APPR DUST RESP
Ventilation:LOC EXHST IF NEC. MECH VENTILATION
Other Protective Equipment:NO
Supplemental Safety and Health
VAPOR PRESSURE: NEGLIGIBLE. % VOLATILE BY VOL: NEGLIGIBLE. THIS PRODUCT
IS USED AS PART OF D-72 DEVELOPER.
================== Physical/Chemical Properties ==================
Spec Gravity:>1.0
Solubility in Water:APPRECIABLE
Appearance and Odor:WHITE CRYSTAL, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Hazardous Decomposition Products:CO*2
==================== Disposal Considerations ====================
Waste Disposal Methods:MFR RECM LANDFILL, DISPOSE AS SOLID WASTE. STATE
& LOCAL EFFLUENT LAWS TAKE PRECEDENCE. DISPOSE IAW FED, STATE &
LOCAL CODES.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:NITROGEN, COMPRESSED
Resp. Party Other MSDS Num.:NO. 48
CAGE:0KPC9
CAGE:0KPC9
CAGE:0FUP3
CAGE:98437
============= Composition/Information on Ingredients =============
Ingred Name:NITROGEN
CAS:7727-37-9
RTECS #:QW9700000
= Wt:100.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NITROGEN IS DEFINED AS A SIMPLE
ASPHYXIANT. EFFECTS OF EXPOSURE TO HIGH CONCENTRATIONS SO AS TO
DISPLACE THE OXYGEN IN AIR NECESSARY FOR LIFE MAY INCLUDE ANY, ALL
OR NONE OF THE FOLLOWING: LOSS OF BAL ANCE OR DIZZINESS. TIGHTNESS
IN THE FRONTAL AREA OF THE FOREHEAD. NITROGEN IS NONTOXIC BUT THE
LIBERATION OF A LARGE AMOUNT IN A CONFINED AREA COULD DISPLACE THE
AMOUNT OF OXYGEN IN AIR NECESSARY TO S UPPORT LIFE.
Explanation of Carcinogenicity:NITROGEN IS NOT LISTED IN THE IARC, NTP
OR BY OSHA AS A CARCINOGEN OR POTENTIAL CARCINOGEN.
Effects of Overexposure:TINGLING OF THE TONGUE, FINGERTIPS OR TOES.
WEAKENED SPEECH LEADING TO THE INABILITY TO UTTER SOUNDS. RAPID
REDUCTION IN THE ABILITY TO PERFORM MOVEMENTS. REDUCED
CONSCIOUSNESS OF THE SURROUNDINGS. LO SS OF TACTILE SENSATIONS.
HEIGHTENED MENTAL ACTIVITY. IT SHOULD BE RECOGNIZED THAT IT IS
POSSIBLE THAT NONE OF THE ABOVE SYMPTOMS MAY OCCUR IN GAS ASPHYXIA
SO THAT THERE ARE NO DEFINITE WARNING SYMPTO MS.
Medical Cond Aggravated by Exposure:PERSONS IN ILL HEALTH WHERE SUCH
ILLNESS WOULD BE AGGRAVATED BY EXPOSURE TO NITROGEN SHOULD NOT BE
ALLOWED TO WORK WITH OR HANDLE THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:PROMPT MEDICAL ATTENTION IS MANDATORY IN ALL CASES OF
OVEREXPOSURE TO NITROGEN. RESCUE PERSONNEL SHOULD BE EQUIPPED WITH
SELF-CONTAINED BREATHING APPARATUS. INHALATION: CONSCIOUS PERSONS
SHOULD BE ASS ISTED TO AN UNCONTAMINATED AREA AND INHALE FRESH AIR.
QUICK REMOVAL FROM THE CONTAMINATED AREA IS MOST IMPORTANT.
UNCONSCIOUS PERSONS SHOULD BE MOVED TO AN UNCONTAMINATED AREA,
GIVEN ASSISTED RESPIRAT ION AND SUPPLEMENTAL OXYGEN. FURTHER
TREATMENT SHOULD BE SYMPTOMATIC AND SUPPORTIVE.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:NONFLAMMABLE, INERT GAS.
Fire Fighting Procedures:IF CYLINDERS ARE INVOLVED IN A FIRE, SAFELY
RELOCATE OR KEEP COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:CYLINDERS WILL RUPTURE OR EXPLODE IN THE
HEAT OF FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL PERSONNEL FROM AFFECTED AREA. USE
APPROPRIATE PROTECTIVE EQUIIPMENT. IF LEAK IS IN CONTAINER OR
CONTAINER VALVE, CONTACT YOUR CLOSEST SUPPLIER LOCATION OR CALL THE
======================Handling and Storage ======================
Handling and Storage Precautions:USE ONLY WELL-VENTILATED AREAS. VALVE
PROTECT CAPS MUST REMAIN IN PLACE UNLESS CYL SECURED W/VALVE
OUTLET PIPED USE POINT. DO NOT DRAG, SLIDE, OR ROLL CYLINDERS. USE
A HAND TRUCK FOR CYL MOVEMENT. U SE PRESSUR REDUCING REGULATR
CONNECTING CYLINDER TO LOWER PRESSURE(<3,000 PSIG)PIPING OR
SYSTEMS.
Other Precautions:DO NOT HEAT CYLINDER BY ANY MEANS TO INCREASE
DISCHARGE RATE OF PRODUCT. USE CHECK VALVE/TRAP IN DISCHARGE LINE
TO PREVENT HAZARDOUS BACKFLOW IN CYLINDER. COMPRESSED GAS CYLINDERS
SHOULD NOT BE REFILL ED EXCEPT BY QUALIFIED PRODUCERS OF COMPRESSED
GASES. ALWAYS SECURE CYLIND IN UPRIGHT POSITION BEFOR E
TRANSPORTING THEM.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:POSITIVE PRESSURE AIR LINE WITH MASK OR
SELF-CONTAINED BREATHING APPARATUS SHOULD BE AVAILABLE FOR
EMERGENCY USE.
Ventilation:USE LOCAL EXHAUST: TO PREVENT ACCUMULATION OF HIGH
CONCENTRATIONS SO AS TO REDUCE THE OXYGEN LEVEL IN THE AIR TO LESS
THAN 18 MOLAR PERCENT.
Other Protective Equipment:SAFETY SHOES.
Work Hygienic Practices:USE IN A WELL VENTILATED AREA.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:G3
Boiling Pt:=-195.8C, -320.5F
Melt/Freeze Pt:=-209.9C, -345.9F
Vapor Pres:@70F(21.1C)ABOVE CRITICAL
Vapor Density:.0725 LB/F
Spec Gravity:@70F(21.1C)=0.97
Solubility in Water:VERY SLIGHTLY
Appearance and Odor:COLORLESS, ODORLESS GAS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT ATTEMPT TO DISPOSE OF WASTE OR UNUSED
QUANTITIES. RETURN IN THE SHIPPING CONTAINER PROPERLY LABELED WITH
ANY VALVE OUTLET PLUGS OR CAPS SECURED AND VALVE PROTECTION CAP IN
PLACE TO YOUR SUPPLIE R. FOR EMERGENCY DISPOSAL ASSISTANCE, CONTACT
NUMBER LISTED HEREIN.
=================== MSDS Transport Information ===================
Transport Information:PSN: NITROGEN, COMPRESSED, 2.2, UN1066.
===================== Regulatory Information =====================
SARA Title III Information:REPORTING UNDER SARA TITLE III SEC 313 NOT
REQUIRED.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:1210 OSHA ORANGE (NEW FORMULATION)
CAGE:09800
CAGE:09800
============= Composition/Information on Ingredients =============
Ingred Name:N-BUTYL ALCOHOL (SARA III)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: < 5%
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYLENE CHLORIDE(SARA III)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 25%
OSHA PEL:500 PPM/C,1000; Z2
ACGIH TLV:50 PPM, A2; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 10%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 10%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 10%
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:ANESTH.SKIN,UPPER RESP SYS IRRIT.POSS
LIGHT-HEADED,STAGGER GAIT,GIDDY,NAUS.HARMFUL/FATAL IF INGEST.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF H*2O FOR @ LEAST 15 MIN. SKIN: WASH
W/SOAP & H*2O. INHAL: REMOVE PATIENT TO FRESH AIR. INGEST: CALL
PHYSICIAN IMMEDIATELY.DO NOT INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point:PROPLNT <20F,TOC
Extinguishing Media:CO*2,DRY CHEMICAL/FOAM.
Fire Fighting Procedures:USE PRESS DEMAND SCBA,FULL PROT CLTHG.USE H*2O
TO COOL CNTNR
Unusual Fire/Explosion Hazard:DONT SPRAY NEAR OPEN FLM.EXP TO
SUNLIGHT/OTHR HEAT POSS BURSTING.THERMAL DECOMP PROD HCL,PHOSGENE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION,VENTILATE,AVOID
BREATHING VAPORS.REMOVE W/INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F.KEEP @ ROOM
TEMP.EXP TO DIRECT SUNLIGHT/HEAT MAY CAUSE BURSTING.DONT
PUNCTURE/INCINERATE.DONT SPRAY NEAR FIRE/OPEN FLAME.
Other Precautions:REPORTS ASSOC RPTD,PRLNG OVEREXP TO SLVT W/PERM
BRAIN,NERVOUS SYS DAMAGE.NO SMOKING IN AREA.DONT USE IN GENL
VICINITY OF ARC WELDG,OPEN FLM/HOT SURF.HEAT/UV RADIATION POSS
HCL,PHOSGENE FORMED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP PROT DEPENDING ON
CONDITION OF USE.
Ventilation:LOCAL EXHAUST VENT IN VOLUME & PATTERN TO KEEP BELOW TLV.
Other Protective Equipment:USE UNPERFORATED SIDE SHIELDS W/GLASSES.
Supplemental Safety and Health
OTHR INGRED:ISOBUTANE,15%,1000 PPM (MFR),PROPELLANT;PROPANE,15%,1000
PPM,SIMPLE ASPHYXIANT,PROPELLANT. % VOLATILE BY WT:84. PRODUCT
REFORMULATED IN MAY 1985.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:PROPLNT <0F
Vapor Density:> 1
Evaporation Rate & Reference:> ETHER(PROPELANT)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:DO NOT STORE ABOVE 120F.
Hazardous Decomposition Products:BY OPEN FLAME-CO,CO*2,HCL,PHOSGENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE. DISPOSE IAW FEDERAL,STATE &
LOCAL REGULATIONS REGARDING POLLUTION.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HYDROGEN PEROXIDE 35%
CAGE:9V101
CAGE:9V101
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 65%
Ingred Name:STABILIZER
Fraction by Wt: <5%
Ingred Name:HYDROGEN PEROXIDE
CAS:7722-84-1
RTECS #:MX0900000
Fraction by Wt: 35%
Other REC Limits:1 PPM
OSHA PEL:1.4 MG/CUM
ACGIH TLV:1.4 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: MAY CAUSE CHEMICAL BURNS.
INHALATION: IRRITATION/CHEMICAL BURNS TO MUCOUS MEMBRANES &
RESPIRATORY SYSTEM. INGESTION: CHEMICAL BURNS AS WELL AS INJURY BY
DISTENTION OF THE ESOPHAGUS/STOMACH DUE TO SUDDEN EVOLUTION OF
GASES.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:BURNS, IRRITATION.
======================= First Aid Measures =======================
First Aid:SKIN/EYES: FLUSH W/LARGE AMOUNTS OF WATER FOR 15 MINS.
INGESTION: DRINK LARGE AMOUNTS OF WATER TO DILUTE. SIT UPRIGHT.
INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN ALL
CASES. NOTE TO P HYSICIAN: IT MAY BE ADVISABLE TO INSERTA GASTRIC
TUBE TO RELIEVE/PREVENT INCREASED PRESSURE THAT MAY RESULT FROM THE
RAPID EVOLUTION OF OXYGEN UPON DECOMPOSITION.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:WATER
Fire Fighting Procedures:WEAR SCBA & PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:STRONG OXIDIZER: HYDROGEN PEROXIDE ISN'T
FLAMMABLE BUT CAN INITIATE SPONTANEOUS COMBUSTION OF
PAPER/WOOD/CLOTH/ORGANIC MATERIALS. IGNITION MAY BE RAPID. (SUPP)
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH W/LARGE AMOUNTS OF WATER. DON'T RETURN
MATERIAL TO ORIGINAL CONTAINER. PREVENT UNDILUTED HYDROGEN PEROXIDE
FROM ENTERING SEWAGE SYSTEM.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID HEATING HYDROGEN PEROXIDE &
STORE AWAY FROM COMBUSTIBLES. DON'T CONTAMINATE.
Other Precautions:STORAGE CONTAINERS/VESSELS MUST BE VENTED & MADE OF
COMPATIBLE MATERIALS SUCH AS 304/316 STAINLESS STEEL/HIGH PURITY
ALUMINUM.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SCBA SHOULD BE AVAILABLE.
Other Protective Equipment:POLYVINYL CHLORIDE SLICKER SUIT, SAFETY
SHOWER/EYEWASH, RUBBER BOOTS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
UNUSUAL FIRE CONT'D: RAPID OXYGEN EVOLUTION FROM DECOMPOSING HYDROGEN
PEROXIDE MAY INCREASE THE INTENSITY OF A FIRE. OXYGEN ENRICHMENT OF
POORLY VENTILATED ORGANIC ATMOSPHERES INCREASES THE POTENTIAL OF
VAPOR PHASE EXPLOSIONS. UNUSUAL FIRECONT'D: DELAYED FOR SEVERAL
HOURS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:226F
Melt/Freeze Pt:M.P/F.P Text:-26F
Vapor Pres:23
Spec Gravity:1.131
Evaporation Rate & Reference:(BU AC =1): <1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID. CONCENTRATIONS >35% MAY
HAVE SHARP ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HEAVY METALS & THEIR SALTS, REDUCING AGENTS, STRONG OXIDIZERS, ALKALIS
& PARTICULATE SOLIDS, COMBUSTIBLES.
Stability Condition to Avoid:INCREAING TEMP, LARGE VOLUMES OF OXYGEN &
STEAM, HEAT.
Hazardous Decomposition Products:OXYGEN, STEAM, PEROXIDE VAPOR & HEAT.
==================== Disposal Considerations ====================
Waste Disposal Methods:DILUTE W/LARGE AMOUNTS OF WATER THEN FLUSH TO
SEWER. DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS. UN2014.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:NEOPRENE REPAIR CEMENT, NEUTRAL
Kit Part:Y
CAGE:7X236
Contract Num:SP0760-02-V-0281
CAGE:7X236
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
= Wt:45.
OSHA PEL:SEE TABLE Z-2
ACGIH TLV:188 MG/M3;50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HEXANE
CAS:110-54-3
RTECS #:MN9275000
= Wt:31.
OSHA PEL:1800 MG/M3;500 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:POLYCHLOROPRENE
CAS:9010-98-4
RTECS #:EI9640000
Ingred Name:NATURAL CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:GR # 1397250002-5027P
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:ACUTE: NAUSEA AND/OR NARCOSIS.
CHRONIC: MAY CAUSE NERVE DAMAGE. TARGET ORGANS: TOLUENE, BASED ON
ANIMAL DATA, MAY CAUSE LIVER ABNORMALITIES, KIDNEY, LUNG & SPLEEN
DAMAGE. IN HUMANS, LIVER ABNORMALITIE S. HEXANE MAY CAUSE CENTRAL
NERVOUS SYSTEM EFFECTS OR DAMAGE PERIPHERAL NERVE TISSUE.
Explanation of Carcinogenicity:CARCINOGENICITY: NO.
Effects of Overexposure:IRRITATION TO EYES AND MUCOUS MEMBRANES.
DRYNESS AND CRACKING OF SKIN. LIQUID INGESTION MAY CAUSE VOMITING.
NUMBNESS, TINGLING AND WEAKNESS OF ARMS OR LEGS.
Medical Cond Aggravated by Exposure:RESPIRATORY AILMENTS.
======================= First Aid Measures =======================
First Aid:UTILIZE THE SUGGESTED METHODS LISTED BELOW. IN EMERGENCY
SITUATIONS NOTIFY A PHYSICIAN. SKIN: WASH WITH SOAP AND WATER.
REFER TO PHYSICIAN IF IRRITATION PERSISTS. EYES: FLUSH EYES
ABUNDANTLY WITH CLEA N WATER AND REFER TO A PHYSICIAN. INGESTION:
DO NOT INDUCE VOMITING. REFER TO A PHYSICIAN. EXCESSIVE INHALATION:
REMOVE PATIENT TO FRESH AIR OR GIVE OXYGEN. USE CPR IF PATIENT IS
NOT BREATHING. REFER TO PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:<-17.6C, 0.F
OF HEXANE
Autoignition Temp:=265.6C, 510.F
Lower Limits:1.0
Upper Limits:7.5
Extinguishing Media:CO2, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:NIOSH/MSHA APPROVED SELF-CONTAINED BREATHING
APPARATUS SHOULD BE WORN. USE WATER SPRAY TO COOL FIRE-EXPOSED
STRUCTURES AND DISPERSE VAPOR-CLOUD IF FIRE IS NOT PRESENT.
Unusual Fire/Explosion Hazard:VAPOR IS HEAVIER THAN AIR AND MAY TRAVEL
CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASHBACK.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SPILL IN SAND, EARTH, VERMICULITE,
OIL-DRI, OR SOL-SPEED-DRI. SHOVEL ABSORBED MATERIAL INTO STEEL
CONTAINER AND COVER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY CLOSED AND
STORE IN APPROVED SOLVENT STORAGE AREA. KEEP AWAY FROM OPEN FLAME,
HEAT, SPARKS, HOT SURFACES AND OXIDIZING AGENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH-APPROVED ATMOSPHERE SUPPLYING OR AIR
PURIFYING RESPIRATOR FOR ORGANIC VAPORS AS REQUIRED TO MAINTAIN
EXPOSURE LEVELS BELOW RECOMMENDED LIMITS.
Ventilation:LOCAL EXHAUST: REMOVE VAPORS DURING PROCESSING. MECHANICAL
EXHAUST: EXPLOSION-PROOF EQUIPMENT. SPECIAL: REDUCE VAPOR
CONCENTRATIONS BELOW SPECIFIED LIMITS
Other Protective Equipment:PROTECTIVE CLOTHING AS REQUIRED TO PREVENT
SKIN CONTACT.
Work Hygienic Practices:KEEP AREA CLEAN. CLEAN UP SPILLS IMMEDIATELY.
PRACTICE GOOD PERSONAL HYGIENE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:=65.C, 149.F
B.P. Text:OF HEXANE
Vapor Pres:65@20C OR 68F
Vapor Density:3.1
Spec Gravity:0.862
Appearance and Odor:TAN LIQUID; CHARACTERISTIC SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:AVOID HEAT, OPEN FLAMES, SPARKS, HOT
SURFACES, AND OXIDIZING AGENTS.
Hazardous Decomposition Products:OXIDES OF CARBON, ZINC, MAGNESIUM,
SULFUR. HYDROGEN CHLORIDE. HYDROGEN SULFIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE, AND
LOCAL CHEMICAL AND SOLVENT WASTE DISPOSAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:PSN: ADHESIVES, UN1133.
===================== Regulatory Information =====================
State Regulatory Information:CONTAINS TOLUENE, A CHEMICAL KNOWN TO THE
STATE OF CALIFORNIA TO CAUSE REPRODUCTIVE TOXICITY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:OXYGEN/NITROGEN GAS MIXTURE
CAGE:7U103
CAGE:7U103
============= Composition/Information on Ingredients =============
Ingred Name:OXYGEN
CAS:7782-44-7
RTECS #:RS2060000
Fraction by Wt: 50%
Ingred Name:NITROGEN
CAS:7727-37-9
RTECS #:QW9700000
Fraction by Wt: 50%
ACGIH TLV:SIMPLE ASPHYXIANT
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:OXYGEN BELOW 21%: ASPHYXIATION -
SYMPTOMS INCLUDE DIZZINESS, HEADACHE, NAUSEA & LOSS OF
CONSCIOUSNESS. OXYGEN ABOVE 21%: ASPHYXIATION - CHEST PAIN, A
VARIETY OF CENTRAL NERVOUS SYSTEM MANIFESTATIONS I NCLUDING
TINGLING EXTREMETIES.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE LISTED.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE VICTIM TO FRESH AIR. IF BREATHING HAS STOPPED,
GIVE ARTIFICIAL RESPIRATION &, IF NEEDED, OXYGEN. GET MEDICAL AID.
EXCESS OXYGEN:MOVE VICTIM TO FRESH AIR. GET MEDICAL AID.
INGEST:CALL MD IMM EDIATELY . SKIN:FLUSH W/COPIOUS AMOUNTS OF
WATER. CALL MD . EYES:IMMEDIATELY FLUSH W/POTABLE WATER FOR A
MINIMUM OF 15 MINS. SEEK ASSISTANCE FROM MD .
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE CONDITIONS
.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . OXYGEN IS NON-FLAMMABLE BUT SUPPORTS &
VIGOROUSLY ACCELERATES COMBUSTION OF FLAMMABLES.
Unusual Fire/Explosion Hazard:SOME MATERIALS WHICH ARE NONCOMBUSTIBLE
IN AIR WILL BURN IN ANY OXYGEN-ENRICHED ATMOSPHERE.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP THE FLOW OF GAS. VENTILATE THE AREA.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE & USE CYLINDER IN A
WELL-VENTILATED AREA AWAY FROM EXCESSIVE HEAT. MOVE CYLINDERS W/A
HAND TRUCK.
Other Precautions:MAKE SURE ALL RESIDUAL VAPORS ARE REMOVED PRIOR TO
BEGINNING R & M.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF NEEDED, A NIOSH/MSHA APPROVED SCBA.
Ventilation:LOCAL RECOMMENDED.
Other Protective Equipment:SAFETY SHOES.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Solubility in Water:SLIGHT
Appearance and Odor:COLORLESS, ODORLESS GAS.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
FLAMMABLES.
Stability Condition to Avoid:KEEP AWAY FROM EXCESSIVE HEAT.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:REPLACE CYLINDER VALVE OUTLET PLUG. REPLACE THE
CYLINDER CAP. IF NO LEAKS ARE OBSERVED, RETURN THE CYLINDER TO YOUR
SUPPLIER.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FFF PUMICE, 620
CAGE:SYNKO
CAGE:0KKF9
CAGE:SYNKO
============= Composition/Information on Ingredients =============
Ingred Name:NON HAZARDOUS INGREDIENT
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: HYPERSENSITIVE INDIVIDUALS MAY
EXPERIENCE SOME SKIN SENSITIZATION OR IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMEDIATELY WITH LARGE AMOUNT OF WATER FOR AT
LEAST 15 MINUTES. TAKE TO MD FOR MEDICAL TREATMENT. SKIN: WASH
AFFECTED AREAS WITH SOAP AND WATER FOR AT LEAST 15 MINUTES. CONSULT
MD IF IRRIT ATION PERSISTS. INGEST: DRINK 1 OR 2 GLASSES OF WATER
TO DILUTE. DO NOT INDUCE VOMITING. CONSULT MD IMMEDIATELY. INHAL:
MOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP) .
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT MATERIAL SUCH AS SAND TO PICK UP
EXCESS, WASH AREA WITH SOAP AND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE CONTAINERS BETWEEN 40 & 100F.
PROTECT FROM FREEZING.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:OPEN WINDOW.
Other Protective Equipment:FULL LENGTH CLOTHING TO AVOID PROLONGED &
REPEATED CONTACT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:<15%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS. BEFORE ATTMPTING CLEAN-UP, REFER TO HAZARD
CAUTION INFORMATION.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SKD-S SPOT CHK DEVL(OLD FORMULA,NSN CANLD)
CAGE:37676
CAGE:37676
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ACETATE (SARA III)
CAS:141-78-6
RTECS #:AH5425000
Fraction by Wt: <50.0%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETONE (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: <40.0%
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: <10.0%
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM/30000STEL;93
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:IRRITATES EYES.
Effects of Overexposure:INHALATION:CAUSES DIZZINESS,DROWSINESS,NAUSEA;
SKIN:LIQUID IRRITATES BY DISSOLVING SKIN OIL; EYES:VAPORS/LIQUID
CAUSES IRRITATION.
Medical Cond Aggravated by Exposure:NOT KNOWN
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR.IF BREATHING IS DIFFICULT,GIVE
OXYGEN; SKIN:REMOVE CONTAMINATED CLOTHES.WASH OFF WITH FLOWING
WATER.USE SOOTHING LOTION.IF IRRITATION PERSISTS,GET MEDICAL ATTN;
EYES:IMM EDIATELY RINSE/FLUSH WITH COPIOUS AMOUNT OF RUNNING
WATER,AND GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE,FOAM
Fire Fighting Procedures:KEEP CONTAINERS COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:AEROSOL CANS CAN BURST IF HEATED ABOVE
130F(54.4C).
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES.SM QTY:WIPE UP OR MOP
UP BUT DO NOT BREATHE VAPORS.PLACE RAGS IN CLOSED DRUMS; LG
QTY:WEAR PERSONAL SAFETY EQUIPMENTS.DIKE AREA FAR AHEAD.ABSORB
LIQUID WITH COMMERCIAL ABSORBEN T.TRANSFER WASTE MATL IN SALVAGE
TANKS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HEAT SOURCES IN WELL
VENTILATED AREA.AVOID AGAINST PHYSICAL DAMAGE TO CONTAINERS.KEEP
CONTAINERS TIGHTLY CLOSED.
Other Precautions:DO NOT BREATHE VAPORS.DO NOT SMOKE WHILE USING.DO NOT
HEAT ABOVE 130F(54C).AVOID FREQUENT OR PROLONGED SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A RESPIRATOR WITH ABSORBENT CARTRIDGE IN
POORLY VENTILATED AREAS.IN CONFINED,UNVENTILATED SPACES,WEAR FULL
MASK WITH AIR SUPPLY.
Ventilation:GENERAL VENTILATION TO KEEP BELOW TLV LIMITS.
Work Hygienic Practices:WASH HANDS WITH SOAP/WATER AFTER HANDLING/USE.
Supplemental Safety and Health
ITEM IS ONE PART PRODUCT.THE QPL 25135-15 ALSO COVERS MULTIPLE
PRODUCTS(SUCH AS:SKD-NF/ZP-9B,SKD-HT,SKD-LT,ZP-9E,& ZP/9F
DEVELOPERS) OF SAME COMPANY UNDER FORM "D",TYPE "II" OF
MIL-I-25135D;THIS IS SK D-S.THIS NSN (ESTABLISHED IN 1987) IS FOR
TYPE II,FORM D PRODUCTS;SEE OTHER PNI FOR ALL OTHER TYPE II,FORM D
ITEMS.
================== Physical/Chemical Properties ==================
HCC:V3
Spec Gravity:0.9 (OF LIQUID)
Evaporation Rate & Reference:0.5 (ETHER=1)
Solubility in Water:MODERATE
Appearance and Odor:WHITE LIQUID BEFORE FILLING IN AEROSOL CANS
Percent Volatiles by Volume:90.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALI METALS,ACIDS
Stability Condition to Avoid:HEAT/HIGH TEMPERATURES.
Hazardous Decomposition Products:WHEN INVOLVE IN COMBUSTION,EMITS
OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AS EPA HAZARDOUS WASTE D001
(IGNITABLE WASTE),IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL,STATE,LOCAL REGULATIONS.EMPTY AEROS CANS BEFORE
DISCARDING.PRESSURIZED AEROSOL CANS ARE NOT AN ACCEPT ABLE WASTE.DO
NOT INCINERATE CANS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:EXTRA LIFE AW 220 HYDRAULIC OILS, 0034
CAGE:VNCLN
CAGE:VNCLN
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MILDLY IRRITATING TO EYES.
HABITUAL POOR PERSONAL HYGIENE MAY LEAD TO SKIN IRRITATION AFTER
PROLONGED OR REPEATED CONTACT. AVOID INHALATION IF HEATED OR
MISTED. MAY CAUSE CHEMICAL PNEUMONITIS. LOW TOXICITY ON INGESTION.
CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/COPIOUS AMTS OF WARM WATER FOR AT LEAST 15 MIN.
MD ASSESSMENT IF EYES INFLAMED. SKIN: REMOVE CONTAM CLTHG. LAUNDER
BEFORE REUSE. WASH SKIN W/SOAP & WATER. DISCARD CONTAM LEATHER
ARTICLES . INHAL: EVACUATE TO FRESH AIR. ASSIST RESP (CARDIOPULM
RESUSCITATION). IF RESUSCITATION REQUIRED, MD ASSESSMENT MANDATORY.
INGEST: DO NOT INDUCE VOMIT. FORCE FLUIDS. ACTIVATED CHARCOAL (SUP
DAT)
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>349F,>176C
Extinguishing Media:USE DRY CHEMICAL, WATER SPRAY, CARBON DIOXIDE, FOR
SMALL FIRES.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. CONTAIN SPILL. COVER W/EXTING AGENT. USE WATER SPRAY TO COOL
FIRE-EXPOSED CONTRS & AS PROT (SUP DAT)
Unusual Fire/Explosion Hazard:ADDITION OF WATER OR FOAM MAY CAUSE
FROTHING.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL. ABSORB WITH INERT ABSORBENT.
SCOOP UP INTO DRUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, WELL-VENTILATED AREA.
KEEP AWAY FROM HEAT AND SOURCES OF IGNITION. AVOID BREATHING OIL
MIST AND VAPORS OF HOT OIL.
Other Precautions:AVOID PROLONGED OR REPEATED SKIN CONTACT. PRACTICE
GOOD PERSONAL HYGIENE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMAL USE, NOT NECESSARY. IF DUST AND/OR MIST
IS GENERATED, USE NIOSH/MSHA APPROVED DUST AND MIST RESPIRATOR IN
AREAS WITH ADEQUATE OXYGEN.
Ventilation:GENERAL VENTILATION. LOCAL EXHAUST IF NECESSARY, TO
MAINTAIN TLV.
Other Protective Equipment:OIL-RESIST APRON &/CLTHG IF DIRECT CONT
W/LIQ IS LIKELY. ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
Work Hygienic Practices:PRACTICE GOOD PERSONAL HYGIENE.
Supplemental Safety and Health
SPEC GRAV: 0.85-0.88 (H*2O=1). FIRE FIGHT PROC: SCREEN. DO NOT POINT
SOLID WATER STREAM DIRECTLY INTO BURNING OIL TO AVOID SPREADING.
FIRST AID PROC: TABLETS. HAS LAXATIVE EFT. GET MED ATTN.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>572F,>300C
Vapor Pres:0.01 KPA
Spec Gravity:SUP DAT
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR-DARK AMBER LIQUID, WITH HYDROCARBON ODOR
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS (STRONG ACIDS, PEROXIDES, CHLORINE, ETC).
Stability Condition to Avoid:HEAT, FORMATION OF OIL MIST.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, ON
COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR LANDFILL. DISPOSE OF IN ACCORDANCE
W/LOCAL, STATE & FEDERAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MS-944/CO2 SAFEZONE SOLVENT CLEANER
Preparer's Name:JANET STEPHENS
CAGE:18598
CAGE:18598
============= Composition/Information on Ingredients =============
Ingred Name:SUPP DATA:DO NOT GIVE STIMULANTS. GET MD IMMED. NEVER GIVE
ANYTHING BY MOUTH TO UNCON PERS. TAKE IMMED TO HOSP (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:OR MD. NOTE TO MD:BECAUSE OF POSS DISTURBANCE OF
CARDIAC RHYTHM, CATECHOLAMINE DRUGS, (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:SUCH AS EPINEPHRINE, SHOULD BE CONSIDERED ONLY AS A
LAST RESORT IN LIFE-THREATENING EMERGENCIES.
RTECS #:9999999ZZ
Ingred Name:VAP PRESS:10.8 PSIA.
RTECS #:9999999ZZ
Ingred Name:EXPLO HAZ:ACIDS & CARBONYL HALIDES SUCH AS PHOSGENE.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP:SENSIT OF MYOCARDIUM TO EPINEPHRINE IN LAB
ANIMALS & COULD HAVE A SIMILAR EFFECT IN HUMANS. (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:ADRENOMIMETICS (E.G., EPINEPHRINE) MAY BE
CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINING USES IN HUMANS (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:ACUTELY OR CHRONICALLY EXPOSED TO CHLOROCARBONS .
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:CHLORIDES, FLUORIDES &/OR PHOSGENE .
RTECS #:9999999ZZ
Ingred Name:ETHANE,
1,1-DICHLORO-1-FLUORO-;(1,1-DICHLORO-1-FLUOROETHANE)
CAS:1717-00-6
RTECS #:KI0997000
Fraction by Wt: 96%
Other REC Limits:500 PPM (MFR)
Ozone Depleting Chemical:2
Ingred Name:METHANOL
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 3.9%
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHANE, NITRO-;(NITROMETHANE)
CAS:75-52-5
RTECS #:PA9800000
Fraction by Wt: 0.1%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: 3%
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM/30000STEL;93
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:AT LOW LEVEL CONC SYMPS MAY
INCLUDE HEADACHE, DIZZINESS, NAUSEA, LOSS OF CONCENTRATION, AND
IRRITATION. WITH HIGH EXPOSURE LEVELS:INTOXICATION, CARDIAC
ARRHYTHMIA. PRODUCT VAPORS DISPLACE AIR & CAN CAUSE ASPHYXIATION
ESPECIALLY IN CONFINED SPACES. SKIN:DEFATTING OF SKIN CAN CAUSE
IRRITATION. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:NO ABSORPTION TOX DATA IS AVAIL.
EYE:IRRITANT. LIQ CNTCT WILL IRRITATE EYES/MAY CAUSE CONJUNCT.
INGEST:SIMILAR SYMPS AS FOR INHAL. DISCOMFORT DUE TO VOLATILITY
WOULD BE EXPECTED. ALSO, IN SUF FICIENT QTYS, CAN CAUSE EYE DMG
INCL BLINDNESS DUE TO METHANOL COMPONENT. CHLOROFLUOROCARBON MATLS
HAVE CAUSED (ING 10)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE TO FRESH AIR. GIVE MOUTH-TO-MOUTH RESUSCITATION IF
BRTHG STOPPED. GIVE O*2 AS NEC IF QUALIFIED OPERATOR AVAIL. DO NOT
GIVE ADRENALIN (EPINEPHRINE). GET MD IMMED. EYE:FLUSH W/LRG AMTS OF
WAT ER FOR AT LEAST 15 MINS, LIFTING EYELIDS OCCASIONALLY UNTIL NO
EVIDENCE OF CHEM REMAINS. GET MD. SKIN:WASH IMMED W/SOAP & WATER
FOR AT LEAST 15 MINS WHILE REMOVING CONTAM CLTHG/SHOES. (SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Lower Limits:7.5%
Upper Limits:19.2%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL OR WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:PRESSURIZED AEROSOL CNTNRS AT ELEV TEMPS
MAY VENT, RUPTURE OR BURST & ADD TO FLYING & FALLING DEBRIS. DECOMP
PROD CAN INCL HYDROCHLORIC & HYDRORFLUORIC (ING 9)
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AND VENTILATE AREA. REMOVE POSSIBLE
IGNITION SOURCES. ONLY PERSONNEL EQUIPPED WITH PROPER RESPIRATORY
SPILL, COLLECT ON ABSORBEN T MATERIAL AND TRANSFER TO STEEL DRUMS
FOR DISP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE NEAR SOURCES OF HEAT, IN
DIRECT SUNLIGHT OR WHERE TEMPERATURES EXCEED 120F/49C. ROTATE STOCK
TO SHELF LIFE OF ONE YEAR.
Other Precautions:KEEP CNTNR CLSD WHEN NOT IN USE. AVOID PRLNGD/RPTD
BRTHG OF VAPS. USE ONLY W/ADEQ VENT. NO SMOKING IN AREA OF USE. DO
NOT USE IN GEN VICINITY OF ARC WELDING, OPEN FLAMES OR HOT SURFS.
HEAT &/OR UV RAD IA MAY CAUSE THE FORMATION OF (ING 13)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:ADEQUATE VENTILATION IS REQUIRED TO CONTROL EXPOSURES BELOW
PERMISSIBLE LIMITS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MATLS TO AVOID:ALUMINUM, BARIUM & LITHIUM SHAVINGS) AND STRONG
OXIDIZING AGENTS. FIRST AID PROC:GET MD IMMED. THORO CLEAN CONTAM
CLTHG & SHOES BEFORE REUSE OR DISCARD. INGEST:IF CONSCIOUS, INDUCE
VOMI T IMMED BY GIVING 2-4 GLASSES OF WATER & TOUCHING FINGER TO
BACK OF THROAT OR REMOVE CHEM BY GASTRIC LAVAGE. (ING 5)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:84.9F,29.4C
Vapor Pres:ING 8
Vapor Density:4
Spec Gravity:1.21 @ 70F
pH:NEUT
Evaporation Rate & Reference:>1 (CCL4=1)
Solubility in Water:BELIEVED SLIGHT
Appearance and Odor:CLEAR COLORLESS LIQUID WITH ETHEREAL ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & ALKALIS/REACTIVE METALS (E.G.,POWDERED ALUMINUM,
SODIUM/POTASSIUM/CALCIUM, MAGNESIUM/ZINC, MOLTEN(SUPDAT)
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:HYROCHLORIC AND HYDROFLUORIC ACIDS,
AND CARBONYL HALIDES SUCH AS PHOSGENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY WITH FEDERAL, STATE AND LOCAL
REGULATIONS. REMOVE TO A PERMITTED WASTE DISPOSAL FACILITY. DO NOT
PUNCTURE OR INCINERATE CANS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:STANNOUS CHLORIDE; TIN II CHLORIDE,CAT #562
CAGE:GFS00
CAGE:GFS00
CAGE:66172
============= Composition/Information on Ingredients =============
Ingred Name:STANNOUS CHLORIDE, SOLID
CAS:7772-99-8
RTECS #:XP8700000
Fraction by Wt: 100%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS 900 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION CAN CAUSE COUGHING,
CHOKING, & INFLAMATION OF THE RESPIRATORY TRACT. SWALLOWING CAN
CAUSE BURNS TO MOUTH & G.I. TRACT. EYE CONTACT CAN CAUSE SEVERE
BURNS & DAMAGE. SKIN CONTACT CAN C AUSE SEVERE BURNS AND DEEP
ULCERS & DISCOLOR SKIN. CHRONIC: CONCENTRATED VAPORS MAY CAUSE
EROSION OF TEETH.
Explanation of Carcinogenicity:HYDROCHLORIC ACID IS NOT LISTED BY IARC,
NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:INFLAMMATION OF THE NOSE, THROAT, UPPER
RESPIRATORY TRACT, EYES, SKIN AND MUCOUS MEMBRANES. VERY CORROSIVE
AND CAN CAUSE SEVERE BURNS AND DAMAGE. LONG TERM EXPOSURES SELDOM
OCCUR DUE TO THE CORROSIVEPROPERTIES OF THE ACID.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
FOR 15 MINUTES HOLDING EYELIDS OPEN. GET IMMEDIATE MEDICAL
ATTENTION. S KIN:REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND
WATER. GET IMMEDIATE MEDICAL ATTENTION. INGESTION:DO NOT INDUCE
VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET IMMEDIATE
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILL: FLUSH WITH WATER AND NEUTRALIZE
WITH ALKALINE MATERIAL. SEWER NEUTRALIZED MATERIAL WITH EXCESS
WATER. LARGE SPILL: EVACUATE AND VENTILATE AREA. IF POSSIBLE, STOP
LEAK. DIKE TO RETAIN RUN OFF. NEUTRALIZE & PICK UP WITH ABSORBENT
MATERIAL.
Neutralizing Agent:SODA ASH, LIME OR OTHER SUITABLE ALKALINE MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT
CONTAINERS FROM PHYSICAL DAMAGE & DIRECT SUNLIGHT.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE MIST. AVOID
PROLONGED OR REPEATED BREATHING OF VAPOR. AVOID CONTACT WITH EYES.
USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING. FOR
INDUSTRIAL USE ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL(TLV), USE NIOSH/MSHA APPROVED FULL FACEPIECE
CHEMICAL CARTRIDGE RESPIRATOR OR A SUPPLIED AIR FULL FACEPIECE
RESPIRATOR OR AIRLINED HOOD.
Ventilation:A SYSTEM OF LOCAL EXHAUST IS RECOMMENDED TO KEEP EMPLOYEE
EXPOSURES BELOW THE TLV.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
IMPERVIOUS BOOTS, APRON, OR COVERALLS AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:NONE
Vapor Pres:NONE
Vapor Density:NONE
Spec Gravity:2.71
pH:NONE
Viscosity:NONE
Evaporation Rate & Reference:NONE
Solubility in Water:COMPLETE
Appearance and Odor:WHITE CRYSTALINE. MAY HAVE FAINT ODOR OF
HYDROCHLORIC ACID
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:WHEN HEATED TO DECOMPOSITION, EMITS
TOXIC HYDROGEN CHLORIDE FUMES. WILL REACT WITH WATER TO PRODUCE
HEAT & TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS. DISPOSE
IN A RCRA-APPROVED WASTE FACILITY OR SEWER THE NEUTRALIZED SLURRY
WITH EXCESS WATER IF LOCAL ORDINANCES ALLOW.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:QUIK FILL NA BATH & BOWL COMPAC
CAGE:DO852
CAGE:DO852
CAGE:85884
============= Composition/Information on Ingredients =============
Ingred Name:N-ALKYL DIMETHYLBENZYL AMMONIUM CHLORIDE
CAS:68391-01-5
Fraction by Wt: 3.0%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: DAMAGE. SKIN: IRRITATION.
INGESTION: IRRITATION/STOMACH DISTRESS. INHALATION: IRRITATION OF
LUNGS/AIRWAYS.
======================= First Aid Measures =======================
First Aid:EYES: IMMED FLUSH W/LOTS OF COOL RUNNING WATER. REMOVE
CONTACTS/KEEP FLUSHING >15 MIN/LIFT LIDS. CALL DR. SKIN: IMMED
FLUSH W/LOTS COOL RUNNING WATER >15 MIN. REMOVE CONTAM
CLOTHES/SHOES/WASH BEFORE R EUSE. INGESTION: IMMED DRINK LOTS
MILK/EGG WHITE/GELATIN SOLUTION/WATER. CALL DR IMMED. INHALATION:
IMMED MOVE TO FRESH AIR. CALL POISON CONTROL OR DR IMMEDIATELY.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:PRODUCT DOES NOT SUPPORT COMBUSTION.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE/DAM LARGE SPILLS. PUMP TO CONTAINERS OR
SOAK UP ON ABSORBENT. FLUSH RESIDUE TO SANITARY SEWER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTAMINATING FOOD/FOOD
PRODUCTS. DON'T STORE W/FOOD.
Other Precautions:KEEP AWAY FROM CHILDREN
============= Exposure Controls/Personal Protection =============
Supplemental Safety and Health
USE SOLUTION PH 9.2
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Spec Gravity:1.0
pH:10.2
Solubility in Water:COMPLETE
Appearance and Odor:BLUE LIQUID, NON-DESCRIPT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
DON'T MIX W/ANYTHING BUT WATER.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT STATE/LOCAL AUTHORITIES FOR RESTRICTION
ON DISPOSAL OF CHEMICAL WASTE. RINSE EMPTY CONTAINER THOROUGHLY
W/WATER BEFORE DISCARDING.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ROYCO 481
Resp. Party Other MSDS Num.:750.004-2
CAGE:07950
Contract Num:SP0450-99-D-4049
CAGE:07950
============= Composition/Information on Ingredients =============
Ingred Name:HYDROTREATED LIGHT NAPHTHENIC DISTILLATE
CAS:64742-53-6
RTECS #:PY8036000
Minumum % Wt:95.
Maxumum % Wt:96.
Ingred Name:SOLVENT REFINED, HYDROTREATED MIDDLE DISTILLATE
CAS:64742-46-7
Code:F
RTECS #:JN9379645
Minumum % Wt:2.
Maxumum % Wt:3.
Ingred Name:MINOR ADDITIVES
< Wt:2.
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES-NOT EXPECTED TO BE MORE THAN
MINIMALLY IRRITATING TO THE EYE. SKIN-PROLONGED OR REPEATED CONTACT
MAY CAUSE VARIOUS SKIN DISORDERS SUCH AS DERMATITIS, FOLICULITIS OR
OIL ACNE. INHALATION-INHALATIO N OF VAPORS (GENERATED AT HIGH
TEMPERATURES ONLY) MILDLY IRRITATING TO THE NOSE, THROAT AND
RESPIRATORY TRACT. INGESTION-INGESTION OF PRODUCT MAY RESULT IN
VOMITING, ASPIRATION (BREATHING) OF VOMITUS INTO THE LUNGS MUST BE
AVOIDED AS EVEN SMALL AMOUNTS MAY RESULT IN ASPIRATION PNEUMONITIS.
Explanation of Carcinogenicity:THIS PRODUCT DOES NOT CONTAIN ANY
CARCINOGEN AS IDENTIFIED BY IARC, NTP, OR OSHA.
Effects of Overexposure:IRRITATION AS PREVIOUSLY NOTED. ASPIRATION
PNEUMONITIS MAY BE EVIDENCED BY COUGHING, LABORED BREATHING AND
CYANOSIS (BLUISH SKIN); IN SEVERE CASES DEATH MAY OCCUR.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN & RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYES-FLUSH WITH WATER. IF IRRITATION OCCURS, GET MEDICAL
ATTENTION. SKIN-REMOVE CONTAMINATED CLOTHES/SHOES & WIPE EXCESS
FROM SKIN. SLUSH SKIN WITH WATER. FOLLOW BY WASHING WITH SOAP &
WATER. IF IRRIT ATION OCCURS, GET MEDICAL ATTENTION. INHALED-REMOVE
VICTIM TO FRESH AIR & PROVIDE OXYGEN IF BREATHING DIFICULT. GET
MEDICCAL ATTENTION. INGESTED-DO NOT INDUCE VOMITING! IF VOMITING
OCCURS SPONTANEOUSL Y, KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION
OF LIQUID INTO THE LUNGS. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:=137.8C, 280.F
Lower Limits:N/AV
Upper Limits:N/AV
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEMICAL OR CARBON DIOXIDE
(CO2). DO NOT USE A DIRECT STREAM OF WATER. PRODUCT WILL FLOAT
AND CAN BE REINGITED ON SURFACE OF WATER.
Fire Fighting Procedures:MATERIAL WILL NOT BURN UNLESS PREHEATED. DO
NOT ENTER CONFINED FIRE SPACE WITHOUT FULL BUNKER GEAR (HELMENT
A POSITIVE PRESSURE NIOS H APPROVED SELF-CONTAINED BREATHING
APPARATUS.COOL FIRE EXPOSED CONTAINERS WITH WATER.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILL: TAKE UP WITH ABSORBENT MATERIAL &
DISPOSE OF PROPERLY. LARGE SPILLS: WEAR RESPIRATOR & PROTECTIVE
CLOTHING AS APPROPRIATE. SHUT OFF LEAK IF SAFE TO DO SO. DIKE &
CONTAIN. REMOVE WITH VAC UUM TRUCKS OR PUMP TO SALVAGE VESSELS.
SOAK UP RESIDUE WITH ABSORBENT SUCH AS CLAY, SAND OR OTHER SUITABLE
MATERIAL. DISPOSE OF PROPERLY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP AWAY FROM OPEN FLAMES & HIGH
TEMPERATURES.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURE MAY OR DOES EXCEED OCCUPATIONAL
EXPOSURE LIMITS (SEC. IV) USE A NIOSH-APPROVED RESPIRATOR TO
PREVENT OVEREXPOSURE. IN ACCORD WITH 29 CFR 1810.134 USE EITHER
AND ATMOSPHERE-SUPPLYING RESP IRATOR OR AN AIR PURIFYING RESPIRATOR
FOR ORGANIC VAPORS AND PARTICULATES.
Ventilation:STORE IN A COOL, DRY, PLACE WITH ADEQUATE VNTILATION. KEEP
AWAY FROM OPEN FLAMES AND HIGH TEMPERATURES.
MINIMIZE CONTACT.
Work Hygienic Practices:AVOID PROLONGED ORE REPEATED CONTACT WITH SKIN.
WASH WITH SOAP AND WATER BEFORE EATING, DRINKING, SMOKING OR USING
TOILET FACILITIES. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:>248.9C, 480.F
Decomp Temp:Decomp Text:NA
Vapor Pres:<0.5 AT
Vapor Density:<0.5
Spec Gravity:0.87
Viscosity:10.3
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT YELLOW OIL; SLIGHT HYDROCARBON ODOR.
================= Stability and Reactivity Data =================
AVOID FLAME AND CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOD HEAT.
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCTS ARE
HIGHLY DEPENDENT ON THE COMBUSTION CONDITIONS. A COMPLEX MIXTURE
OF AIRBORNE SOLID, LIQUID, PARTICULATES AND GASES WITH EVOLVE WHEN
THIS MATERIAL UNDERGOES PYROLYSIS.
Conditions to Avoid Polymerization:WILL NOT OCCUR
=================== Toxicological Information===================
Toxicological Information:NONE SPECIFIED BY MANUFACTURER.
===================== Ecological Information =====================
Ecological:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:IF PRODUCT BECOMES A WASTE, IT WOULD NOT BE A
HAZARDOUS WASTE BY RCRA CRITERIA (40 CFR 261). PLACE IN AN
APPROPRIATE DISPOSAL FACILITY IN COMPLIANCE WITH LOCAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:NOT REGULATED.
===================== Regulatory Information =====================
SARA Title III Information:NONE SPECIFIED BY MANUFACTURER.
Federal Regulatory Information:THE COMPONENTS OF THIS PRODUCT ARE
LISTED IN THE EPA/TSCA INVENTORY OF CHEMICAL SUBSTANCES.
State Regulatory Information:NONE SPECIFIED BY MANUFACTURER.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:RUST SCAT URETHANE ENAMEL 31
Preparer's Name:RAJ DHAWAN
CAGE:33200
CAGE:33200
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT; (MINERAL SPIRITS). VP: 2.0.
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 35-45%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: CAN CAUSE SEVERE IRRITATION,
REDNESS, TEARING, BLURRED VISION. SKIN: PROLONGED OR REPEATED
CONTACT CAN CAUSE MODERATE IRRITATION, DEFATTING, DERMATITIS.
INHALATION: EXCESSIVE INHALATION OF VAPOR S CAN CAUSE NASAL AND
RESPIRATORY IRRITATION, DIZZINESS, WEAKNESS, FATIGUE, NAUSEA,
HEADACHE, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: POSSIBLE UNCONSCIOUSNESS AND EVEN
ASPHYXIATION. INGESTION: CAN CAUSE GASTROINTESTINAL IRRITATION,
NAUSEA, VOMITING AND DIARRHEA. ASPIRATION INTO LUNGS CAN CAUSE
CHEMICAL PNEUMONITIS WHICH CA N BE FATAL.
Medical Cond Aggravated by Exposure:NO KNOWN.
======================= First Aid Measures =======================
First Aid:SKIN: THOROUGHLY WASH EXPOSED AREA W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
EYES: FLUSH W/LARGE AMOUNTS OF WATER LIFTING UPPER & LOWER LIDS
OCCASIONALL Y. GET MEDICAL ATTENTION. INGEST: DO NOT INDUCE
VOMITING. KEEP PERSON WARM & GET MEDICAL ATTENTION. INHAL: REMOVE
TO FRESH AIR. IF BREATHING IS DIFFICULT, ADMINISTER OXYGEN. IF
BREATHING HAS (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:102F,39C
Lower Limits:1.05
Upper Limits:6.0%
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND MAY
TRAVEL ALONG THE GROUND OR BE MOVED BY VENTILATION AND IGNITED BY
HEAT, PILOT LIGHTS OR OTHER FLAMES AND IGNITION (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB LIQUID ON PAPER, VERMICULITE, FLOOR
ABSORBENT OR OTHER ABSORBENT MATERIAL AND PICK UP WITH SHOVEL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PROLONGED OR REPEATED SKIN
CONTACT. KEEP AWAY FROM HEAT, SPARKS, OPEN FLAMES. USE WITH
ADEQUATE VENTILATION.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED SELF CONTAINED RESPIRATOR IF TLV
IS REACHED.
Ventilation:LOCAL EXHAUST AS NEEDED TO REMAIN BELOW PEL.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
BARRIER CREAM.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPEC GRAV: 0.95-1.15 (H*2O=1). EXPLO HAZ: SOURCES AT LOCATIONS DISTANT
FROM MATERIAL HANDLING POINT. FIRST AID PROC: STOPPED, APPLY
ARTIFICIAL RESPIRATION. KEEP PERSON WARM, QUIET & GET MEDICAL
ATTENT ION.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:300F,149C
Vapor Pres:SEE ING 1
Vapor Density:HVR/AIR
Spec Gravity:SUPDAT
VOC Grams/Liter:3.8
Evaporation Rate & Reference:70 (ETHER=1)
Solubility in Water:NONE
Appearance and Odor:WHITE OR COLORED OPAQUE LIQUID; MINERAL SPIRITS
ODOR.
Percent Volatiles by Volume:56-63
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
DIOXIDE AND/OR CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE UNDER SAFE CONDITIONS. DISPOSE OF IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:COATING, ALIPH. POLYUR. TAN 686A, 33446 ID 705131
Preparer's Name:W A ELLISON
CAGE:FO127
CAGE:FO127
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ISOBUTYL KETONE (SOLVENT) (SARA III) (VAPOR
PRESSURE 16 MM HG @ 20C) (LFL 1.0; UFL 8.0)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 15%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM;STEL 75 PPM
ACGIH TLV:50 PPM;STEL 75 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SOLVENT NAPTHA, HEAVY AROMATIC (SOLVENT)
CAS:64742-94-5
RTECS #:SE7546500
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
Ingred Name:N-BUTYL ACETATE (SOLVENT) (VAPOR PRESSURE 10 MM HG @ 20C)
(LFL 1.7; UFL 7.6)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM;STEL 200 PPM
ACGIH TLV:150 PPM;STEL 200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENE (SARA III) (VAPOR PRESSURE 5 MM HG @ 20C) (LFL 1.0;
UFL 7.0)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM;STEL 150 PPM
ACGIH TLV:100 PPM;STEL 150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (SOLVENT) (SARA III) (VAPOR PRESSURE 22 MM HG @
20C) (LFL 1.7; UFL 7.1)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 5%
Other REC Limits:SKIN
OSHA PEL:100 PPM;STEL 150 PPM
ACGIH TLV:100 PPM; 147 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SILICA, CRYSTALLINE - QUARTZ (PIGMENT)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.1000 MG/M3
ACGIH TLV:0.1000 MG/M3
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE (PIGMENT)
CAS:14464-46-1
RTECS #:VV7325000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.05000 MG/M3
ACGIH TLV:0.05000 MG/M3
Ingred Name:SILICA, AMORPHOUS - DIATOMACEOUS EARTH (PIGMENT)
CAS:68855-54-9
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:06 MG/M3
ACGIH TLV:10 MG/M3; 20 MPPCF
Ingred Name:SILICA, CRYSTALLINE
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.1000 MG/M3
ACGIH TLV:0.1000 MG/M3
Ingred Name:TITANIUM DIOXIDE (PIGMENT)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:ISOPHORONE DIISOCYANATE (RESIN) (SARA III) (SKIN) (VAPOR
PRESSURE 1 MM HG @ 20C)
CAS:4098-71-9
RTECS #:NQ9370000
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:.005 PPM;0.020 MG/M3
ACGIH TLV:.005 PPM;0.045 MG/M3
Ingred Name:DIBUTYL TIN DILAURATE (ADDITIVE)
CAS:77-58-7
RTECS #:WH7000000
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.1000 MG/M3
ACGIH TLV:0.1000 MG/M3 (SKIN)
Ingred Name:POLYMERIC HEXAMETHYLENE DIISOCYANATE (RESIN)
CAS:28182-81-2
RTECS #:HQ9170000
Fraction by Wt: 25%
Other REC Limits:MFR: 1 MG/M3
Ingred Name:SOLVENT NAPHTHA, LIGHT AROMATIC (SOLVENT)
CAS:64742-95-6
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
Ingred Name:1,6 HEXAMETHYLENE DIISOCYANATE
CAS:822-06-0
RTECS #:MO1740000
Fraction by Wt: <0.100%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.0050 PPM
ACGIH TLV:.0050 PPM;0.035MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CHROMIUM III OXIDE (SARA III) (FOR CARCINOGENICITY
INFORMATION, SEE INGREDIENT FIELD # 17)
CAS:1308-38-9
RTECS #:GB6475000
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.5000 MG/M3
ACGIH TLV:0.5000 MG/M3
Ingred Name:SUPPLIER CONCLUDES CHROMIUM III OXIDE NOT CARCINOGENIC.
IARC LIST CHROMIUM & CERTAIN CHROMIUM COMPOUNDS GROUP 1 CARCIN
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
Ingred Name:VOC: 3.49 LB/GAL LESS WATER & NEGLIGIBLY PHOTOCHEMICALLY
REACTIVE MATERIALS; 419 G/L LESS WATER; CALCULATED
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:UNKNOWN IARC:YES
Health Hazards Acute and Chronic:INGEST:FATAL,GI
IRRIT,NAUSEA,VOMIT.ASPIRATION INTO LUNGS-CHEM PNEUMONITIS.
INHAL:HARMFUL,LUNG DAMAGE,IRRIT,ALLERGIC RESP REACTION(MAY BE
PERMANENT),RESP SENSITIZATN,NOSE/THROAT IRRIT,ACUTE CENTRL NERV
SYS DEPRESS(HEADACHE,DIZZY,NAUSEA,CONFUSION).EYE:SEVERE IRRIT.
SKIN:ABSORBD IN HARMFUL AMT,IRRIT,SENSITIZTN,DEFAT,IRRIT
Explanation of Carcinogenicity:CRYSTALLINE SILICA (IARC) LIMITED
EVIDENCE-HUMAN, SUFFICIENT EVIDENCE-ANIMAL. FOR MORE CARCINOGEN
INFO SEE INGRED # 17.
Effects of Overexposure:CHRONIC: SILICOSIS (DISABLING LUNG DISEASE),
LIVER, KIDNEY, BLOOD INJURY. RESP SENSITIZATION, RESP SENSITIVITY
(ASTHMA LIKE SYMPTOMS). PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
CONCENTRATING & INHALING CONTENTS MAY BE HARMFUL/FATAL.
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY CONDITIONS
MAY BE AGGRAVATED BY EXPOSURE TO CRYSTALLINE SILICA.
======================= First Aid Measures =======================
First Aid:INGEST: DON'T INDUCE VOMIT. CALL POISON CNTRL CTR, EMERG
ROOM, DR IMMED. INHALATION: REMOVE TO FRESH AIR IMMED. IF BREATH
STOPPED, GIVE ARTIF RESP. KEEP WARM & QUIET. GET MED AID IMMED.
EYE: FLUSH W/W ATER 15 MIN, LIFTING EYELIDS. GET MED AID. SKIN:
REMOVE CONTAM CLOTHING. WASH AFFECTED AREA W/SOAP & WATER. GET MED
AID IF IRRIT PERSISTS. NOTES TO DR: DIRECT TREATMENT AT
SYMPTOMS/CLINICAL CONDITIONS
===================== Fire Fighting Measures =====================
Flash Point:40.0F,4.4C
Autoignition Temp:Autoignition Temp Text:572 F
Lower Limits:1.0
Upper Limits:8.0
Extinguishing Media:NFPA CLASS B EXTINGUISHERS (CO2, DRY CHEMICAL,
ALCOHOL FOAM) FOR FLAMMABLE LIQ. POLYMER FOAM PREFERRED FOR LARGE
FIRES.
Fire Fighting Procedures:WEAR SCBA. WATER MAY BE INEFFECTIVE, MAY BE
USED TO COOL (FOG NOZZLES PREFFERED) EXPOSED CNTNRS TO PREVENT
PRESSURE BUILD-UP, AUTOIGNITION, EXPLOSION WITH HEAT.
Unusual Fire/Explosion Hazard:DURING EMERG CONDITIONS, OVEREXPOSURE TO
DECOMPOSITION PRODUCTS MAY BE HEALTH HAZARD. SYMPTOMS MAY NOT BE
IMMEDIATELY APPARENT. OBTAIN MEDICAL AID. FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:USE TC19C AIR SUPPLD BREATH APPARATUS.WEAR
RSPRTR,EYE,HAND,BODY PROTECT.KEEP SPECTATOR AWAY.ELIMINATE IGNIT
SOURCE.DIKE W/INERT MAT'L(SAND,EARTH,ETC).TRANSFR LIQ/USED ABSORB
TO CVRD METAL CNTNR.USE NO N-SPARK TOOL.PREVENT
SEWER,STREAM,GROUNDWTR CONTAM
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE >115 F.STORE LRG QTY IN
COMPLY W/OSHA 29CFR1910.106.DON'T EAT.CLOSE CNTNR AFTER USE.DON'T
BREATHE SANDING DUST/VAPOR,GET IN EYE/SKIN/CLOTH
Other Precautions:DON'T USE IF HAVE HAD CHRONIC BREATHING
PROBLEMS/ISOCYANATE REACTIONS.KEEP FROM HEAT/FLAME.USE W/VENT.DON'T
REUSE EMPTY CNTNR.GROUND/BOND CNTNR TO RECEIVING CNTNR.DON'T
WELD/BRAZE,CUT CNTNR.NEVER USE PRESSR TO EMPTY.DRUM NOT PRESSR
VESSEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR FITTED POSITIVE PRESSR AIR SUPPLD RSPRTR
(TC19C). UNAVAILABLE,USE VAPOR PARTIC (PAINT SPRAY) RSPRTR
EFFECTIVE FOR ISOCYANATE VAPOR. WEAR RSPRTR WHILE MIX,SPRAY,TILL
VAPOR GONE. FOLLOW DIRECTN.REF ER TO OSHA 29 CFR 1910.134 RESP
PROTECTN
Ventilation:GENRL DILUTN & LOCAL EXHAUST VENT TO KEEP BELOW TLV.REMOVE
DECOMP PRODUCT.SEE"INDUST VENT-MANUAL RECOMM PRACTICES"ACGIH.
Other Protective Equipment:EYE WASH FACILITY, SAFETY SHOWER. AS
REQUIRED TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F5
Boiling Pt:B.P. Text:231 TO 419F
Melt/Freeze Pt:M.P/F.P Text:-50F,-46C
Decomp Temp:Decomp Text:1832F,1000C
Vapor Pres:22 @ 68F
Vapor Density:> AIR
Spec Gravity:1.2
pH:4-7
Viscosity:65 TO 80 KU
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Solubility in Water:SLIGHT IN WATER
Appearance and Odor:LIQUID, SOLVENT ODOR
Percent Volatiles by Volume:49
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS. OXIDIZING MATERIALS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT (>115F) AND SOURCES
OF IGNITION.
Hazardous Decomposition Products:SMOKE, CO, CO2, OXIDES OF NITROGEN &
OXIDES OF CHROMIUM
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE, AND
LOCAL REGULATIONS. CONTAINS CHROMIUM. WASTE RESIDUE OF THIS PRODUCT
MAY QUALIFY AS HAZARDOUS WASTE. THIS PRODUCT IF DISCARDED DIRECTLY
WOULD BE CLASSIFIE D A HZD WASTE: D001, IGNITABLE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LEX-48 TRU-TEST SUPREME HI-Q ALL ACRYLIC LATEX ENAMEL
CAGE:TRUTE
CAGE:TRUTE
============= Composition/Information on Ingredients =============
Ingred Name:VOL ORGANIC CMPD: <250 GM/L
RTECS #:9999999VO
Ingred Name:DIETHYLENE GLYCOL ETHYL ETHER, CARBITOL, CARBITOL
CELLOSOLVEETHOXY DIGLYCOL, 2-(2-ETHOXYETHOXY)-ETHANOL
CAS:111-90-0
RTECS #:KK8750000
Fraction by Wt: 1-5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF EYES, NOSE,
THROAT, & MUCOUS MEMBRANES OF RESPIRATORY TRACT. SKIN/EYES:
IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: IRRITATION TO EYES, NOSE, THROAT, &
MUCOUS MEMBRANES OF RESPIRATORY TRACT. SKIN/EYES: IRRITATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SKIN: WASH W/SOAP & WATER.
EYES: FLUSH IMMEDIATELY W/LARGE AMOUNTS OF WATER. INGESTION: GIVE 2
GLASSES OF WATER TO DILUTE. DON'T INDUCE VOMITING. OBTAIN MEDICAL
ATTENT ION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:WATER MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE OR BUILD-UP
PRESSURE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE & CONTAIN SPILL W/INERT MATERIAL SUCH AS
SAND OR EARTH. TRANSFER THE LIQUID TO CONTAINERS FOR RECOVERY OR
DISPOSAL. KEEP SPILL OUT OF SEWERS & OPEN BODIES OF WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING. AVOID CONTACT
W/SKIN & EYES. DON'T TAKE INTERNALLY. AVOID INHALATION OF VAPORS OR
SPRAY MISTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN BRUSHED OR ROLLED NONE REQUIRED IF GOOD
VENTILATION MAINTAINED. DURING SPRAY APPLICATION, AN APPROVED
MECHANICAL FILTER RESPIRATOR TO REMOVE AIRBORN PARTICLES OF
OVERSPRAY IS REQUIRED.
Ventilation:SUFFICIENT TO KEEP <TLV.
Other Protective Equipment:EYE WASH FACILITY, PROTECTIVE CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS BEFORE EATING, SMOKING, OR USING WASHROOM.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Vapor Density:<AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:VARIES W/COLOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:EXTREME HEAT & FREEZING
==================== Disposal Considerations ====================
Waste Disposal Methods:LIQUID MATERIAL & CONTAMINATED DIKING MATERIAL
SHOULD BE LANDFILLED ACCORDING TO CURRENT LOCAL, STATE, & FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ROYCO C201/201C
CAGE:07950
CAGE:07950
============= Composition/Information on Ingredients =============
Ingred Name:FLUOROSILICONE OIL; (FLUOROPROPYL SILICONE FLUID) FL PT:
565F, 296C
CAS:63148-56-1
Fraction by Wt: 60-80%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:FLUOROTELOMER MIXTURE
CAS:22-57-5
Fraction by Wt: 10-20%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHYLENE, TETRAFLUORO-, POLYMER; (POLYTETRAFLUOROETHYLENE)
CAS:116-14-3
RTECS #:KX4025000
Fraction by Wt: 5-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CHROMIC ACID, DISODIUM SALT; (SODIUM CHROMATE) (SARA 313)
(CERCLA)
CAS:7775-11-3
RTECS #:GB2955000
Fraction by Wt: <1%
OSHA PEL:C 0.1 MG (CRO3)/M3
ACGIH TLV:0.05 MG(CR)/M3; A1
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:OTHER ADDITIVES
Fraction by Wt: <15%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUP DAT: ADDRESSED BY THESE STUDIES. SEVERAL HEXAVALENT
CHROMIUM CMPDS HAVE BEEN SHOWN TO BE CARCIN IN EARLIER (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: BIOASSAY STUDIES. ONLY CALCIUM CHROMATE HAS
CONSISTENTLY PRDCED LUNG TUMORS IN RATS, BY SEVERAL RTES OF (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: ADMIN. OTHER CHROMIUM CMPDS--STRONTIUM CHROMATE,
ZINC CHROMATE, SODIUM DICHROMATE, LEAD CHROMATE, LEAD (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: CHROMATE OXIDE, & SINTERED CHROMIUM TRIOXIDE--HAVE
PRDCED LOC SARCOMAS/LUNG TUMORS IN RATS AT THE SITE (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: OF INTRABRONCHIAL, INTRATRACHEAL, INTERMUSCULAR,
SUBCUTANEOUS & INTRAPERITONEAL APPLICATION.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: IN GEN, NO TREATMENT IS NEC UNLESS LGE QTYS
OF PROD ARE INGESTED. HOWEVER, GET MED ADVICE. (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: NOTE TO MD: IN GEN, EMESIS INDUCTION IS UNNEC IN
HIGH VISCOSITY, LOW VOLAT PRODS, I.E., MOST OILS & GREASES.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: STOR/SALVAGE VESSELS. SOAK UP RESIDUE W/ABSORB
SUCH AS CLAY, SAND/OTHER SUITABLE MATL. DISP OF (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: PROPERLY. FLUSH AREA W/WATER TO REMOVE TRACE
RESIDUE. SML SPILLS: TAKE UP W/ABSORB MATL & DISP OF PROPERLY.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH: NATIONAL RESPONSE CTR, 800-424-8802.
DISPOSE OF I/A/W LOCAL, STATE & FEDERAL REGULATIONS .
RTECS #:9999999ZZ
Ingred Name:HYGIENE PRACTICES: LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE/SKIN: EXPECTED TO BE NO
MORE THAN MILDLY IRRIT. INHAL: FUMES OF DECOMP PRODS CAN INDUCE
TEMPORARY INFLUENZA-LIKE SYMPS WHICH ARE DESCRIBED AS "POLYMER FUME
FEVER". THESE SYMPS INCL FEVER, C OUGH & MALAISE. INGEST:
CONSIDERED TO HAVE LOW ORDER OF ACUTE ORAL TOX. SIGNS & SYMPS:
IRRIT AS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SODIUM CHROMATE: IARC MONO, VOL 49, PG
49, 1990: GROUP 1. NTP 7TH ANNUAL RPT ON CARCINS, 1994: KNOWN TO BE
CARCIN.
Effects of Overexposure:HLTH HAZ: NOTED ABOVE. PROD HAS NOT BEEN TESTED
IN LONG-TERM CHRONIC EXPOS TESTS, HOWEVER, HNDLG PROC & SFTY PREC
IN THIS MSDS SHOULD BE FOLLOWED TO MIN EXPOS. SEVERAL EPIDEMIOLOGIC
STUDIES OF CHROMAT E PRODUCTION WORKERS HAVE DEMONSTRATED ASSOC OF
EXPOS TO CHROMIUM CMPDS W/RESP CANCER. WHETHER ASSOC IMPLICATES(SUP
DAT)
Medical Cond Aggravated by Exposure:PREEXISTING EYE, SKIN AND
RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO COMPONENTS
OF THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN WHILE
HOLDING EYELIDS OPEN. GET MED ATTN. SKIN: REMOVE CONTAM CLTHG/SHOES
& WIPE EXCESS FROM SKIN. FLUSH SKIN W/WATER. FOLLOW BY WASHING
W/SOAP & WATER . IF IRRIT OCCURS, GET MED ATTN. DO NOTREUSE CLTHG
UNTIL CLEANED. INHAL: REMOVE TO FRESH AIR & PROVIDE OXYGEN IF BRTHG
IS DFCLT. GET MED ATTN. INGEST: DO NOT INDUCE VOMIT. (ING 11)
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:565F,296C
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEMICAL, OR CARBON
DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . MATERIAL WILL NOT BURN UNLESS PREHEATED. COOL
FIRE-EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:HYDROGEN FLUORIDE, A VERY CORROSIVE AND
TOXIC GAS, MAY BE RELEASED UPON COMBUSTION.
================== Accidental Release Measures ==================
Spill Release Procedures:MAY BURN ALTHOUGH NOT READILY IGNITABLE. USE
CAUTIOUS JUDGMENT WHEN CLEANING UP LGE SPILLS. LGE SPILLS: WEAR
NIOSH APPRVD RESP & PROT CLTHG AS APPROP. SHUT OFF SOURCE OF LEAK
IF SAFE TO DO SO. DIKE & CONTAIN. REMOVE W/VACUUM TRUCKS/PUMP
TO(ING 13)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP AWAY FROM OPEN FLAMES AND HIGH
TEMPERATURES.
Other Precautions:AVOID CONTACT WITH EYES. AVOID PROLONGED OR REPEATED
CONTACT WITH SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH APPROVED RESPIRATOR AS REQUIRED TO
PREVENT OVEREXPOSURE. IN ACCORDANCE WITH 29 CFR 1910.134, USE
EITHER AN ATMOSPHERE-SUPPLYING RESPIRATOR OR AN AIR-PURIFYING
RESPIRATOR FOR ORGANIC VAPORS .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH & DELUGE
SHOWER . WEAR CHEMICAL RESISTANT CLOTHING TO MINIMIZE CONTACT.
Work Hygienic Practices:WASH W/SOAP & WATER BEFORE EATING, DRINKING,
SMKNG, APPLYING COSMETICS/USING TOILET FACILITIES. (ING 16)
Supplemental Safety and Health
HAZ DECOMP PROD: STUDIES HAVE SHOWN TFPA TO HAVE AN LD50 OF 25 MG/KG.
TFPA IS, THEREFORE, HIGHLY TOX & PREC TO PVNT ITS EVALUATION SHOULD
BE CONSIDERED. THERMAL DECOMP PRODS ARE HIGHLY DEPENDENT ON CO
MBUST CNDTNS. EFTS OF OVEREXP: HEXAVALENT CHROMIUM (CRVI)
ALONE/TRIVALENT (CRIII) AS WELL, IS NOT DEFINITIVELY (ING 6)
================== Physical/Chemical Properties ==================
Spec Gravity:1.3 (H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:SMOOTH TAN GREASE WITH SLIGHT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID HEAT, FLAME.
Hazardous Decomposition Products:AT TEMPS >300F, FLUOROPROPYL WILL
DECOMPOSE TO PRDCE TRIFLUOROPROPIONALDEHYDE (TFPA) VAPS. ANIMAL
ORAL FEEDING (SUP DAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISP OF AS HAZ WASTE BASED ON CHROMIUM CONTENT,
UNLESS EXTRACTION RSLTS ARE LESS THAN EPA LIMS. UNDER EPA-CWA, THIS
PROD IS CONSIDERED AN OIL UNDER SECTION 311. SPILLS INTO/LEADING TO
SURF WATERS THAT CAUSE SHEEN MUST BE REPORTED TO THE (ING 15)
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:NONE SPECIFIED BY MANUFACTURER.
Preparer's Name:WARREN FRANK, PRES.
CAGE:84583
CAGE:84583
============= Composition/Information on Ingredients =============
Ingred Name:THE MANUFACTURER STATES THAT NO HAZARDOUS INGREDIENTS ARE
PRESENT IN THIS PRODUCT.
RTECS #:9999999ZZ
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Reports of Carcinogenicity:NTP:UNKNOWN IARC:UNKNOWN OSHA:NO
Health Hazards Acute and Chronic:NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:MANUFACTURER STATES THIS ITEM DOES NOT
HAVE ANY HAZARDOUS MATERIAL AND NO CHEMICALS.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:NONE SPECIFIED BY MANUFACTURER.
===================== Fire Fighting Measures =====================
Extinguishing Media:NONE SPECIFIED BY MANUFACTURER.
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
LETTER FROM MANUFACTURER DATED MARCH 23, 1993 STATE THAT THIS ITEM HAS
NO HAZARDOUS MATERIAL OR CHEMICAL AND THAT NO MSDS IS REQUIRED.
LETTER SIGNED BY WARREN FRANK.
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:REPAIR KIT CONTAINING PATCH 101, HOLLAND CLOTH,
ROLLER, PLUS OTHER ITEMS.
================= Stability and Reactivity Data =================
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:NONE SPECIFIED BY MANUFACTURER.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:HIGH CORE
CAGE:DO481
CAGE:DO481
CAGE:20913
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM DISTILLATE
Fraction by Wt: 54.2%
ACGIH TLV:500 PPM (MFR)
Ingred Name:2-BUTOXYETHANOL
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 0.38%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
===================== Hazards Identification =====================
Effects of Overexposure:HEADACHE,NAUSEA,BLURRED VISION.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/PLENTY OF H*20 FOR @ LEAST 15 MIN.SEE A
PHYSICIAN. SKIN:CLEANSE THOROUGHLY. INHAL:REMOVE TO FRESH AIR .
INGEST:DO NOT INDUCE VOMITING.SEE PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:110F (43.3C,TOC
Extinguishing Media:CO*2,FOAM.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE & USE @ MODERATE
TEMPERATURES.KEEP OUT OF EYES.KEEP OUT OF THE REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXP OF CONCERN
Ventilation:MECHANICAL VENTILATION IF USED INDOORS.
Supplemental Safety and Health
SPECIFIC GRAVITY:0.8850-0.9048.
================== Physical/Chemical Properties ==================
Evaporation Rate & Reference:SLOWER THAN H*20.
Solubility in Water:NEG.
Appearance and Odor:DK BROWN,SEMIVISCOUS LIQ;PETROLEUM DISTILLATE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL,STATE &
FEDERAL REGULATIONS. DISPOSE OF AS WITH WASTE LUBRICANTS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:UNIVERSAL INDICATOR SOLUTION
CAGE:57020
CAGE:57020
============= Composition/Information on Ingredients =============
Ingred Name:METHYL RED
CAS:493-52-7
RTECS #:DG8960000
Fraction by Wt: 0.05% %
Other REC Limits:NONE RECOMMENDED
Ingred Name:BROMOTHYMOL BLUE SODIUM SALT
CAS:34722-90-2
Fraction by Wt: 0.08% %
Other REC Limits:NONE RECOMMENDED
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 99.7% %
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 92
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:THYMOL BLUE
CAS:76-61-9
RTECS #:XP2575000
Fraction by Wt: 0.1% %
Other REC Limits:NONE RECOMMENDED
Ingred Name:PHENOLPHTHALEIN
CAS:77-09-8
RTECS #:SM8380000
Fraction by Wt: 0.06% %
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT GIVEN FOR PRODUCT AS A WHOLE
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TOXIC. ABSORBED THROUGH THE SKIN.
ACUTE: IRRITATION AND PAIN TO SKIN, EYES, LUNGS, MUCOUS MEMBRANES
AND GI TRACT. MAY CAUSE NAUSEA, HEADACHE, DIZZINESS, CNS
DEPRESSION, VISION IMPAIRMENT, STAINS SKIN. CHRONIC: BLINDNESS,
DERMATITIS, LIVER/KIDNEY DAMAGE.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:IRRITATION/PAIN TO EYES, SKIN, LUNGS, MUCOUS
MEMBRANES, GI TRACT, NAUSEA, HEADACHE, DIZZINESS, CNS DEPRESSION,
VISION IMPAIRMENT, STAINING OF SKIN, BLINDNESS, DERMATITIS, LIVER
DAMAGE, KIDNEY DAMAGE.
Medical Cond Aggravated by Exposure:PERSONS WITH PREEXISTING SKIN, EYE,
RESPIRATORY OR KIDNEY/LIVER DISORDERS MAY BE MORE SUSCEPTIBLE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH WITH SOAP AND WATER. IF IRRITATION PERSIST, GET MEDICAL
ATTENTION. INH ALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. GET
MEDICAL ATTENTION. INGESTION: INDUCE VOMITING BY GIVING TWO GLASSES
OF WATER AND STICKING FINGER DOWN THROAT. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:51.8F,11.0C
Autoignition Temp:Autoignition Temp Text:385C
Lower Limits:6.70 %
Upper Limits:36.0 %
Extinguishing Media:ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER
SPRAY
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR SELF CONTAINED
BREATHING APPARATUS AND FULL PROTECTIVE GEAR. COOL TANKS AND
CONTAINERS EXPOSED TO FIRE WITH WATER.
Unusual Fire/Explosion Hazard:ABOVE FLASH POINT, VAPOR-AIR MIXTURES ARE
EXPLOSIVE WITHIN FLAMMABLE LIMITS NOTED ABOVE. VAPORS CAN FLOW
ALONG SURFACES TO DISTANT IGNITION SOURCE AND FLASH.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE
ALL SOURCES OF IGNITION (FLAME, SPARK SOURCES, HOT SURFACES).
VENTILATE AREA. CONTAIN AND REMOVE WITH INERT ABSORBENT AND
NON-SPARKING TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, WELL-VENTILATED
PLACE. KEEP CONTAINER TIGHTLY CLOSED WHEN NOT IN USE. READ LABEL ON
CONTAINER BEFORE USING.
Other Precautions:FOR LABORATORY USE ONLY. NOT FOR DRUG, FOOD OR
HOUSEHOLD USE. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ORGANIC CARTRIDGE OR SELF-CONTAINED.
Ventilation:EXHAUST VENTILATION SUFFICIENT TO KEEP AIRBORNE
CONCENTRATIONS BELOW RESPECTIVE TLV'S.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:208F,98C
Melt/Freeze Pt:M.P/F.P Text:149F,65C
Vapor Pres:97
Vapor Density:1.1
Spec Gravity:0.8
Evaporation Rate & Reference:5.9 (N-BUTYL ACETATE=1)
Solubility in Water:NOT GIVEN
Appearance and Odor:YELLOWISH-GREEN SOLUTION, METHYL ALCOHOL ODOR
Percent Volatiles by Volume:99.7%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ALUMINUM, SULFURIC ACID
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
FORMALDEHYDE
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SBS-40 MEDICATED SKIN CREAM
CAGE:DEBUS
CAGE:DEBUS
CAGE:SBSDE
============= Composition/Information on Ingredients =============
Ingred Name:UREA, (2,5-DIOXO-4-IMIDAZOLIDINYL)-; (ALLANTOIN)
CAS:97-59-6
RTECS #:YT1600000
Fraction by Wt: 0.2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:3,5-XYLENOL, 4-CHLORO-; (CHLOROXYLENOL)
CAS:88-04-0
RTECS #:ZE6850000
Fraction by Wt: 0.2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 50-100%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:STEARIC ACID, TETRADECYL ESTER; (CETYL ESTERS)
CAS:17661-50-6
RTECS #:WI4900000
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PETROLATUM
CAS:8009-03-8
RTECS #:SE6780000
Fraction by Wt: 0.1-1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PALMITIC ACID, ISOPROPYL ESTER; (ISOPROPYL PALMITATE)
CAS:142-91-6
RTECS #:RT4900000
Fraction by Wt: 0.1-1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACRYLIC ACID, POLYMERS; (CARBOMER)
CAS:9003-01-4
RTECS #:AT4680000
Fraction by Wt: 0.1-1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHANOL, 2,2',2"-NITRILOTRI-; (TRIETHANOLAMINE)
CAS:102-71-6
RTECS #:KL9275000
Fraction by Wt: 0.1-1%
OSHA PEL:N/K
ACGIH TLV:5 MG/M3
Ingred Name:1-OCTADECANOL; (STEARYL ALCOHOL)
CAS:112-92-5
RTECS #:RG2010000
Fraction by Wt: 0.1-1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CETEARETH-20
CAS:68439-49-6
Fraction by Wt: 0.1-1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:LANOLIN
CAS:8006-54-0
RTECS #:OE3201000
Fraction by Wt: 0.1-1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BENZOIC ACID, P-HYDROXY-, METHYL ESTER; (METHYLPARABEN)
CAS:99-76-3
RTECS #:DH2450000
Fraction by Wt: 0-0.1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BENZOIC ACID, P-HYDROXY-, PROPYL ESTER; (PROPYLPARABEN)
CAS:94-13-3
RTECS #:DH2800000
Fraction by Wt: 0-0.1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:FRAGRANCE
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: TEMPORARY MODERATE IRRITATION.
INGESTION: UNDETERMINED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: AVOID RUBBING EYES. IMMEDIATELY FLUSH WITH CLEAN WATER
WHILE HOLDING EYELIDS APART. CONTINUE FLUSHING FOR AT LEAST 15
MINUTES OR UNTIL IRRITATION SUBSIDES. CONTACT DOCTOR. INGEST:
CONSULT LOCAL POISON CONTROL CENTER. INHAL: REMOVE TOFRESH AIR.
SUPPORT BREATHING (GIVE OXYGEN/ARTIFICIAL RESPIRATION) . SKIN:
FLUSH WITH COPIOUS AMOUNTS OF WATER. SEE MD .
===================== Fire Fighting Measures =====================
Flash Point:212F,100C
Extinguishing Media:WATER SPRAY (FOG), FOAM, DRY CHEMICAL, CARBON
DIOXIDE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . BLANKET FIRE WITH EXTINGUISHING MEDIUM. WATER OR FOAM
MAY CAUSE FROTHING.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE REQUIRED.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED. USE NIOSH APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PH: 5.3-6.3.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Spec Gravity:1.0 (H*2O=1)
pH:SUPDAT
Solubility in Water:APPRECIABLE
Appearance and Odor:LIGHTLY SCENTED WHITE SEMISOLID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARD WITH ORDINARY SOLID WASTES. COMPLY WITH
ALL GOVERNMENT, FEDERAL, STATE AND LOCAL WASTE DISPOSAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PR-1901
CAGE:DO551
CAGE:83574
CAGE:DO551
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA (PETROLEUM SPIRITS OR BENZIN)
CAS:8030-30-6
RTECS #:SE7555000
Fraction by Wt: 97.0%
OSHA PEL:100 PPM
===================== Hazards Identification =====================
Effects of Overexposure:CAUSES HEADACHE,NAUSEA,DROWSINESS.MAY CAUSE
IRRITATION TO EYES & DEFATTING OF SKIN.
======================= First Aid Measures =======================
First Aid:SKIN:WASH THOROUGHLY W SOAP & WATER;EYES:IMMEDIATELY FLUSH
OUT W PLENTY OF WATER,SEE A PHYSICIAN;INHALATION:REMOVE TO FRESH
AIR.GIVE CPR/OXYGEN IF NECESSARY.GET MED HELP.
===================== Fire Fighting Measures =====================
Flash Point:20F CC
Lower Limits:0.90
Upper Limits:6.0
Extinguishing Media:FOAM,CO*2,DRY CHEM
Fire Fighting Procedures:COOL FIRE/HEAT EXPOSED CONTAINERS W WATER
SPRAY
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL:MOP/WIPE UP USING ABSORBENT
MATERIAL.LARGE:ELIMINATE IGN SOURCES & EVACUATE AREA.WEAR
PROTECTIVE EQUIP,STOP LEAT W/O RISK.DIKE AREA & PUMP LIQ TO SALVAGE
TANK.ABSORB REMAINING LIQ W ABSORBENT MA TERIAL & SHOVEL INTO
CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL DRY PLACE AWAY FROM
SOURCE OF HEAT,SPARKS/IGNITION & OPEN FLAME.KEEP IN TIGHTLY CLOSED
CONTAINERS.
Other Precautions:PRODUCT IS MOISTURE SENSITIVE,KEEP CONTN TIGHTLY
CLOSED AFTER USE.NEVER USE WELDING TORCH NEAR CONTAINERS.AVOID
PROLONGED/REPEATED SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQD IF ADEQUATE VENTILATION IS AVAILABLE
Ventilation:LOCAL EXHAUST ADEQUATE TO DISPEL VAPORS
Other Protective Equipment:AS REQD BY LOCAL AUTH.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:212-284F
Vapor Pres:UNK
Vapor Density:UNK
Spec Gravity:0.72
Evaporation Rate & Reference:UNK
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID,NAPHTHA ODOR
Percent Volatiles by Volume:97
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING & CORROSIVE MATERIAL
Stability Condition to Avoid:SOURCE OF IGNITION
Hazardous Decomposition Products:UNK
==================== Disposal Considerations ====================
Waste Disposal Methods:REVIEW ALL LOCAL,STATE & FED REGULATIONS &
STATUTES TO DETERMINE APPROVED METHOD OF SOLVENT DISPOSAL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:EASY-OFF NON-CAUSTIC OVEN CLEANER (LEMON)
CAGE:DO084
CAGE:DO084
CAGE:90994
============= Composition/Information on Ingredients =============
Ingred Name:ISOBUTANE
CAS:75-21-5
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
ACGIH TLV:1900 MG/M3
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: >70%
Other REC Limits:NONE SPECIFIED
Ingred Name:NON-HAZARDOUS ORGANIC AND INORGANIC SALTS
Fraction by Wt: MIXTURE
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NONE OF THE CHEMICALS IN THIS PRODUCT IS
LISTED BY IARC, NTP OR OSHA AS A CARCINOGEN.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:NOT AN EYE IRRITANT. NOT ORALLY TOXIC. NOT A PRIMARY IRRITANT
OR CORROSIVE. NOT TOXIC BY DERMAL EXPOSURE. NOT TOXIC BY
INHALATION.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, CO2, DRY CHEMICAL.
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard:CONTENTS UNDER PRESSURE.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP WITH ABSORBENT MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN! DO NOT
EXPOSE TO HEAT OR STORE AT TEMPERATURE ABOVE 120F. DO NOT PUNCTURE
OR INCINERATE CONTAINER. AVOID FREEZING.
Other Precautions:DON'T USE ON CONTINUOUS CLEANING OVENS. CAN BE USED
ON SELF-CLEANING OVENS IF SELF-CLEANING CYCLE ISN'T USED &
TEMPERATURE DOESN'T EXCEED 475F. DON'T SPRAY ONTO PILOT LIGHT,
ELECTRICAL CONNECTIONS, SW ITCHES, LIGHT BULBS, HEATING ELEMENTS,
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Pres:65-76 @70F
Spec Gravity:1.07
pH:9.8
Solubility in Water:DISPERSES
Appearance and Odor:WHITE OPAQUE FOAM WHEN SPRAYED; LEMON ODOR.
Percent Volatiles by Volume:75%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARD ABSORBED MATERIAL WITH TRASH COLLECTION
OR FLUSH TO SANITARY SEWER.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:ISOPAR G
Kit Part:Y
CAGE:DO849
CAGE:DO849
CAGE:2F871
============= Composition/Information on Ingredients =============
Ingred Name:HYDROTREATED HEAVY NAPHTA(PETROLEUM),CAS#647452-48-9
Fraction by Wt: 100%.
ACGIH TLV:300PPM(MFR)
===================== Hazards Identification =====================
Effects of
Overexposure:EYES:IRRIT;INHAL:IRRITAT,HEAD,DIZZINESS;SKIN:IRRITAT,D
ERMATITIS
======================= First Aid Measures =======================
First Aid:1019
===================== Fire Fighting Measures =====================
Flash Point:100F,38C
Autoignition Temp:Autoignition Temp Text:560F
Lower Limits:0.8
Upper Limits:7.0
Extinguishing Media:FOAM,WTR SPRAY(F0G),DRY CHEM,CO*2 & VAPORIZING TYPE
EXT.AGTS
Fire Fighting Procedures:WTR MAY BE INEFFECT. BUT USE TO KEEP FIRE
EXPSO CONT. COOL.
Unusual Fire/Explosion Hazard:USE SCBA EQUIP.FOR CONFINED SPACES.
================== Accidental Release Measures ==================
Spill Release Procedures:SHUT OFF IGN.SOURCES.KEEP PEOPLE
AWAY.RECOV.FREE PROD.ABS.SPILL W/SAND,EARTH.KEEP PROD.OUT OF SEWER
& WTRCOURSES BY DIKING OR IMPOUNDING.ADVISE AUTH.IF PROD HAS
ENTERED SEWER,WTRCOURSES.MINIMIZE BREAT HG/SKIN CONTACT.VENTIL
CONFINED SPACES.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONT.CLOSED.DO NOT HANDLE/STORE
NEAR HEAT,SPARKS,FLAME,STR.OXIDANTS.EFFECTIVELY GND.PROD.TRANSFER
SYSTEM IAW NFPA STD FOR PETROL.PROD.
Other Precautions:MINIMIZE BREATHG VAP.OR MIT.AVOID CIONTACT
W/SKIN.REMOVE CONTAM.CLTHG:LAUNDR OR DRY-CLN.CLEANSE SKIN
THOR.AFTER CONTACT.USE WTRLESS HAND CLNRS FOLLOWED W/SOAP &WTR.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE SCBA IN CONFINED SPACES IF NEEDED.
Ventilation:PROVIE>60FPM HOOD FACE VEL.USE EXPL.PROOF EQUP.;NO SMOKING
Other Protective Equipment:CHEM.RESIST.APRON
Supplemental Safety and Health
MDSD DATED 07-29-85/BP RANGE:155-176C/PH ESSENTALLY NEUTRAL/VISO
0.99CP/POUR PT <OF, -18 C/MN 149/AUTO0IGN.TEMP.560F,293 C/KEY;NO1;
PART A OF KIT UNDER SAME NSN & FSCM 73877:KEY1:J1.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:311-348F
Vapor Pres:<10
Vapor Density:5.
Spec Gravity:0.75
Viscosity:0.99CP
Evaporation Rate & Reference:0.3
Solubility in Water:NEGLIGIBLE
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STR OXIDANTS LIKE LIQ CHLORINE,CONC.0*2,SOD/CALC HYPOCHLORIT
Stability Condition to Avoid:MFR DID NOT SPECIFY
Hazardous Decomposition Products:FUMES,SMOKE,CO,ALDEHYDES AND OTHER
DECOMP. PRODUCTS
==================== Disposal Considerations ====================
Waste Disposal Methods:ASSURE CONFORMITY WITH APPLICABLE GOVERNMENTAL
REGULATIONS.CONTINUE TO OBSERVE PRECAUTIONS FOR
VOLATILE,COMBUSTIBLE VAP.FROM ABS.MTL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:1126 ULTRALUBE ENGINE OIL SAE 30, MIL-L-2104F MC-3709
CAGE:1L506
CAGE:1L506
============= Composition/Information on Ingredients =============
Ingred Name:LUBRICATING OIL BASESTOCK
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:ZINC SALT OF DIALKYL DITHIOPHOSPHORIC ACID
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ORAL:ACCIDENTAL INGEST MAY CAUSE IRRIT
OF DIGESTIVE TRACT.EYE:MAY CAUSE IRRIT,DIRECT CONTACT MAY CAUSE
BURNING,TEARING,REDNESS.SKIN:IRRIT,PROL/REP CONTACT MAY CAUSE
BURNING,REDNESS,DERM.INHAL:EXPO TOHEATED MIST/VAP MAY CAUSE IRRIT
TO NOSE/THROAT.
Explanation of Carcinogenicity:PER
MSDS:CARCINOGENICITY:NTP/IARC/OSHA:NA.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:ORAL:DO NOT INDUCE VOMIT.CALL PHYSICIAN IMMED. EYE:FLUSH
W/CLEAN WATER.IRRIT/REDNESS PERSISTS SEEK MED ATTN. SKIN:WASH
W/SOAP/WATER.REMOVE CONTAMIN CLOTH.IRRIT/REDNESS PERSISTS SEEK MED
ATTN. INHAL:IR RIT NOSE/THROAT DEVELOPS MOVE AWAY FROMEXPO
SOURCE.IRRIT PERSIST SEEK MED ATTN. ADDTN:MED OPINION DIVIDED FOR
LG INGEST.EMESIS/LAVAGE HAS BEEN RECOMMENDED FOR PETRO PROD WHICH
HAVE HIGH ORAL TOXICITY
===================== Fire Fighting Measures =====================
Flash Point:392F,200C
Autoignition Temp:Autoignition Temp Text:NP
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:EXTINGUISH W/DRY CHEMICAL, CO2,
WATERSPRAY,FOAM,SAND,EARTH.WATER & FOAM MAY CAUSE FROTHING.
REQUIRED FOR FIRE FIGHTING PERSONNEL.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:TREAT AS OIL SPILL.CONTAIN & REMOVE BY
MECHANICAL MEANS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORAMLLY NEEDED.
Ventilation:IF CURRENT VENTI PRACT NOT ADEQUATE IN MAINTAINING AIRBORNE
CONC BELOW ESTABLISHED LIMITS MECH VENTI IS RECOMMENDED.
Other Protective Equipment:NONE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:>500F,>260C
Melt/Freeze Pt:M.P/F.P Text:NA
Decomp Temp:Decomp Text:NP
Vapor Pres:<0.01 @20C
Vapor Density:>AIR
Spec Gravity:0.87-0.88
pH:NEUTRA
Viscosity:NP
Evaporation Rate & Reference:SLOWER THAN ETHER.
Solubility in Water:NEGLIGIBLE.
Appearance and Odor:DARK AMBER LIQUID, MILD ODOR.
Percent Volatiles by Volume:NP
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZERS.
Stability Condition to Avoid:CONDITIONS OF HIGH HEAT MAY CAUSE THERMAL
DECOMPOSITION.
Hazardous Decomposition Products:THERM DECOMP IN PRESENCE OF AIR YIELD
MAJOR AMTS OF OXIDES OF CARBON & MINOR AMTS OF OXIDES OF S, N, P,
ZN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPO MUST BE IAW APPLICABLE LOCAL, STATE AND
FEDERAL REGULATIONS.ENCLOSED-CONTROLLED INCINERATION IS RECOMMENDED
UNLESS DIRECTED OTHERWISE BY APPLICABLE ORDINANCES.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SC9022522 SYNCORE HC 9823 K40
CAGE:33564
CAGE:33564
============= Composition/Information on Ingredients =============
Ingred Name:EPOXY POLYMER
Ingred Name:POLYAMINE
Ingred Name:INERT CARRIERS
Fraction by Wt: 30-60%
Ingred Name:VOLATILE ORGANIC CONTENT: <10 GM/L (ESTIMATE)
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: UNCURED ADHESIVE MAY IRRITATE.
REPEATED/PROLONGED CONTACT W/UNCURED ADHESIVE MAY RESULT IN
ALLERGIC SENSITIZATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, RASH
Medical Cond Aggravated by Exposure:SKIN SENSITIZATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WASH THOROUGHLY W/SOAP
& WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION: DRINK PLENTY
OF WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL/HALON FIRE EXTINGUISHER, WATER SPRAY,
FOAM/FOG
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS & FULL
PROTECTIVE CLOTHING, SUCH AS TURN-OUT GEAR.
Unusual Fire/Explosion Hazard:MAY LIBERATE LARGE QUANTITIES OF DENSE
FOUL-SMELLING SMOKE WHICH MAY CONTAIN UNIDENTIFIED TOXIC GASES.
EXCESSIVE HEATING MAY CAUSE EXOTHERM.
================== Accidental Release Measures ==================
GLASSES. PICK UP/SHOVEL INTO DOT APPROVED WASTE CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:MAY BE STORED AT 0F FOR UP TO 12
MONTHS. REFRIGERATED STORAGE IS RECOMMENDED TO MAINTAIN PRODUCT
QUALITY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NECESSARY W/ADEQUATE EXHAUST VENTILATION.IF
DRY SANDING/GRINDING, USE A NIOSH/MSHA APPROVED RESPIRATOR FOR
DUST.
Ventilation:LOCAL EXHAUST AT THE POINT OF USE.
SHOWER
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Pres:0
Vapor Density:>1
Spec Gravity:2-2.5
Solubility in Water:NEGLIGIBLE
Appearance and Odor:SOLID WHITE TO YELLOW TAPE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG LEWIS/MINERAL ACIDS
Stability Condition to Avoid:HEATING IN MASSES >1 LB TOTAL. AVOID
HEATING UNLESS CURING SURFACES TO BE BONDED.
Hazardous Decomposition Products:CO, NITROGEN OXIDES, ALDEHYDES, ACIDS
& UNDETERMINED ORGANICS
Conditions to Avoid Polymerization:HEATING IN MASSES >1 LB TOTAL. AVOID
HEATING UNLESS CURING SURFACES TO BE BONDED.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATION IN AN EPA-APPROVED WASTE
INCINERATOR IS A PREFERRED DISPOSAL PRACTICE. DISPOSE OF IN
ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS & NATURAL/SYNTHETIC RUBBER COMPOSITION
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TARTAC 30
Preparer's Name:THOMAS J. TAYLOR III
CAGE:TO241
Contract Num:SP0560-99-D-5025
CAGE:36446
CAGE:TO241
============= Composition/Information on Ingredients =============
Ingred Name:NONHAZARDOUS
= Wt:100.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NO HAZARD BEYOUND THAT OF ORDINARY
COMBUSTIBLE HYDROCARBON MATERIALS. PROLONGED SKIN CONTACT MAY
IRRITATE SKIN. EXCESSIVE INHALATION OF HOT VAPORS MAY IRRITATE
RESPIRATORY SYSTEM.
Explanation of Carcinogenicity:NONE ESTABLISHED.
Effects of Overexposure:SKIN CONTACT-REDNESS, ITCHING OR BURNING.
INHALATION-COUGHING, DIZZINESS, DROWSINESS.
Medical Cond Aggravated by Exposure:RESPIRATORY AILMENTS, DERMATITIS.
======================= First Aid Measures =======================
First Aid:EYES-FLUSH WITH COPIOUS AMOUNTS OF WATER. SKIN-WASH WITH SOAP
AND WATER. INHALATION OF HOT VAPORS-REMOVE VICTIM TO FRESH AIR.
APPLY CPR IF INDICATED. IN ALL CASES, CONSULT PHYSICIAN IF
INDICATED.
===================== Fire Fighting Measures =====================
Flash Point Method:OC
Flash Point:=148.9C, 300.F
Extinguishing Media:WATER FOG, FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:DO NOT USE WATER ON BULK MATERIAL AS IT MAY
CAUCASE FOAMING.
Unusual Fire/Explosion Hazard:VAPORS FROM HOT OR BURNING MATERIAL MAY
CAUSE EXPLOSIVE MIXTURES WITH AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER BULK MATERIAL IF POSSIBLE. SOAK UP
WITH SAND OR OTHER ABSORBENT AND REMOVE TO DISPOSAL AREA.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM EXCESSIVE HEAT OR
FLAME. SECURE SOURCES OF IGNITION WHILE HANDLING.
Other Precautions:USE PRECAUTIONS OF HANDLING ORDINARY COMBUSTIBLE
LIQUIDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELF-CONTAINED BREATHING APPARATUS IF MATERIAL
IS HOT.
Ventilation:MECHANICAL/(GENERAL) USE IN VENTILATED AREA.
Other Protective Equipment:WEAR PROTECTIVE CLOTHING WHERE HOT MATERIAL
MAY CONTACT SKIN.
Work Hygienic Practices:ORDINARY MEASURES OF PERSONAL HYGIENE SHOULD BE
SUFFICIENT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V5
Boiling Pt:=337.8C, 640.F
Spec Gravity:1.00
Appearance and Odor:DARK, VICIOUS LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:STABLE UNLESS MIXED WITH STRONG OXIDIZING
AGENTS OR CERTAIN POLYMERIZATION.
Hazardous Decomposition Products:NONE
Conditions to Avoid Polymerization:WILL NOT OCCUR
==================== Disposal Considerations ====================
Waste Disposal Methods:BURY IN AUTHORIZED LAND FILL AREA.
=================== MSDS Transport Information ===================
Transport Information:CLASSIFIED AS NONHAZARDOUS UNDER D.O.T.
===================== Regulatory Information =====================
Federal Regulatory Information:CLASSIFIED AS NONHAZARDOUS UNDER RCRA
REGULATIONS.
State Regulatory Information:
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PLCD2-3Y, CUSTOM PLASMA STANDARD 10,000 PPM (SUPDAT)
Preparer's Name:SUSHA RAMONE
CAGE:04XT3
CAGE:04XT3
============= Composition/Information on Ingredients =============
Ingred Name:NITRIC ACID; (HNO*3) (SARA 302/313) (CERCLA). LD50: (ORAL,
RAT) 225 MG/KG.
CAS:7697-37-2
RTECS #:QU5775000
Fraction by Wt: 2-5%
OSHA PEL:2 PPM
ACGIH TLV:2 PPM; 4 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:CADMIUM NITRATE (II), TETRAHYDRATE (1:2:4); (CD)
CAS:10022-68-1
RTECS #:EV1850000
Fraction by Wt: 0.1-1.0%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 90-97%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MATL TO AVOID: AS ALCOHOL, WOOD, TURPENTINE, METAL POWDERS,
HYDROGEN SULFIDE, ETC. CONTACT W/STRONG BASES WILL (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: CAUSE VIOLENT SPLATTERING.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP: LATENT PERIOD OF 4-10 HRS AFTER
INTOXICATION SYMPS ARE: NASOPHARYNGEAL IRRIT, FEELING OF CHEST (ING
7)
RTECS #:9999999ZZ
Ingred Name:ING 6: CONSTRICTION, COUGH, DYSPNEA, HDCH, CHILLS, MUSC
ACHES, NAUS, VOMIT, BURNING SENSATION, WHEEZ, LARYNGITIS (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: & SHORTNESS OF BRTH. PULM EDEMA MAY DEVELOP & CAUSE
REDUCED CARBON MONOXIDE DIFFUSING CAPACITY. IN ABOUT (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: 20% OF CASES, DYSPNEA IS PROGRESSIVE ACCOMPANIED BY
WHEEZ OR HEMOPTYSIS & MAY RSLT IN DEATH W/IN 7-10 (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: DAYS. INCRD INCIDENCE OF PROSTATIC CANCER REPORTED
FOLLOWING EXPOS TO CADMIUM & ITS SALTS. CONCENTRATED (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:NITRIC ACID MAY BE FATAL IF TOO MUCH
INHALED/ABSORBED THRU SKIN. VAP/MIST IS IRRITANT OF EYES, MUC MEMBS
(ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: & SKIN. EYE CNTCT PRDCES SEV BURNS WHICH MAY RSLT
IN PERM DMG & VISUAL IMPAIRMENT. ON SKIN, LIQUID OR (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: CONCENTRATED VAP PRDCES IMMED, SEVERE & PENETRATING
BURNS; CONCENTRATED SOLNS CAUSE DEEP ULCERS & STAIN (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: SKIN BRIGHT YELLOW OR YELLOWISH BROWN COLOR. VAP &
MIST MAY ERODE EXPOS TEETH W/PRLNGD EXPOS. INGEST OF (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: LIQ WILL CAUSE IMMED PAIN & BURNS OF MOUTH,
ESOPHAGUS & GI TRACT. INHAL MAY BE FATAL CAUSING SPASM, (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: INFLAM & EDEMA OF LARYNX & BRONCHI, CHEM PNEUMIT &
PULM EDEMA. SYMPS INCL BURNING SENSATION, COUGH, (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: WHEEZING, LARYNGITIS, SHORTNESS OF BRTH, HDCH, NAUS
& VOMIT. THIS MATL IS NOT KNOWN TO CONTAIN ANY CHEM (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17: LISTED AS A CARCIN OR SUSPECTED CARCIN BY OSHA,
IARC OR NTP.
RTECS #:9999999ZZ
Ingred Name:EYE PROT: & FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SYMPS & HLTH HAZS FOR DILUTE NITRIC
ACID ARE EXPECTED TO BE LESS SEV THAN EXPOS TO CONCENTRATED NITRIC
ACID. HOWEVER, SINCE NITRIC ACID IS IN SOLN AT 1% (OR 10,000 PPM)
OR GREATER, HLTH HAZS FOR CONCE NTRATED NITRIC ACID ARE GIVEN. THIS
SOLN MAY BE HARMFUL IF INHALED, INGESTED OR CONTACTED W/SKIN OR
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:CADMIUM NITRATE: IARC MONOGRAPHS, VOL
58, PG 119, 1993:GROUP 1.
Effects of Overexposure:HLTH HAZ: EYES. CADMIUM SALTS ARE CONSIDERED
CARCIN ACCORDING TO OSHA, NTP & IARC. CADMIUM DUST CAUSES BOTH
ACUTE & CHRONIC EFTS. DUST IS LESS TOXIC THAN FUME DUE TO LARGER
PARTICLE SIZE. ACUTE EFTS P RIMARLY EFT LUNGS BUT MAY ALSO EFT
OTHER ORGANS SUCH AS KIDNEY. CHRONIC POIS TO LUNGS IS IRREVERSIBLE.
FOLLOWING (ING 6)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MINUTES OCCASIONALLY
LIFTING UPPER & LOWER EYELIDS. SKIN: REMOVE CONTAMINATED CLOTHING,
THEN FLUSH W/WATER FOR AT LEAST 15 MINUTES. WASH CLOTHING
THOROUGHLY BEFORE REUSE. INHAL: RMOVE TO FRESH AIR. INGEST: DO NOT
INDUCE VOMITING. GET IMMED MED HELP. IF PATIENT IS CONSCIOUS, GIVE
LARGE QUANTITIES OF WATER OR MILK. IF IRRITATION CONTINUES, GET
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:APPROPRIATE TO SURROUNDING FIRE CONDITIONS.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CONCENTRATED HNO*3 IS NOT COMBUST BUT IS
STRONG OXIDIZER & ITS HEAT OF RXN W/REDUCING AGENTS OR COMBUSTS MAY
CAUSE IGNIT. CAN REACT W/METALS TO RELS (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA. DILUTE SPILL W/WATER & NEUT W/SODA
ASH, LIMESTONE, ETC. WIPE UP & PUT INTO SEALED CNTNR FOR PROPER
DISP. WASH SPILL SITE OFF W/WATER AFTER MATL PICK UP IS COMPLETE.
Neutralizing Agent:SODA ASH, LIMESTONE, ETC.
======================Handling and Storage ======================
Handling and Storage Precautions:CONCENTRATED NITRIC ACID WILL ATTACK
SOME FORMS OF PLASTICS, RUBBER & COATINGS. STORE AT ROOM TEMP. KEEP
TIGHTLY SEALED WHEN NOT IN USE.
Other Precautions:WARNING: IRRITANT. CORROSIVE. CARCINOGEN. HAVE
IMMEDIATE AVAILABILITY OF AN EYE WASH IN CASE OF EMERGENCY. AVOID
INHALATION, INGESTION AND CONTACT WITH EYES AND SKIN. WASH
CAREFULLY AFTER USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH APPROVED RESPIRATOR.
Ventilation:USE IN A CHEMICAL FUME HOOD.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
WEAR CHEMICAL RESISTANT CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO: CADMIUM IN 5% NITRIC ACID. EXPLO HAZ: FLAM
HYDROGEN GAS. CONCENTRATED HNO*3 REACTS EXPLOSIVELY W/COMBUST
ORGANIC OR READILY OXIDIZABLE MATLS SUCH AS ALCOHOL, WOOD,
TURPENTINE , METAL POWDERS, HYDROGEN SULFIDE, ETC.
================== Physical/Chemical Properties ==================
Spec Gravity:APPROX 1
Solubility in Water:SOLUBLE
Appearance and Odor:TRANSPARENT WITH AN ACRID ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONCENTRATED HNO*3 IS POWERFUL OXIDIZING AGENT. IT REACTS EXPLO
W/COMBUST ORG OR READILY OXIDIZABLE MATLS SUCH (ING 4)
Stability Condition to Avoid:STABLE UNDER NORM STORAGE & USE. ELEVATED
TEMPS MAY CAUSE CONTAINERS TO BURST & LIBERATE TOXIC OXIDES OF
NITROGEN.
Hazardous Decomposition Products:WILL RELEASE TOXIC NITROGEN OXIDE
FUMES AND VAPORS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT LOCAL HAZARDOUS CHEMICAL WASTE DISPOSAL
AGENCY FOR FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:INDUSTRIAL X-RAY DEVELOPER/REPLENISHER, PART B
Kit Part:Y
CAGE:59710
CAGE:0P7P7
CAGE:59710
CAGE:59735
============= Composition/Information on Ingredients =============
Ingred Name:ACETIC ACID (CERCLA)
CAS:64-19-7
RTECS #:AF1225000
Fraction by Wt: 65-70%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 PPM
ACGIH TLV:10 PPM/15 STEL; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:DIETHYLENE GLYCOL
CAS:111-46-6
RTECS #:ID5950000
Fraction by Wt: 25-30%
Other REC Limits:NONE RECOMMENDED
Ingred Name:1-PHENYL-3-PYRAZOLIDONE
CAS:92-43-3
RTECS #:UQ8750000
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT GIVEN FOR PRODUCT AS A WHOLE
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SEVERE EYE IRRITATION AND
BURNING. MAY CAUSES SEVERE SKIN IRRITATION AND BURNING. INHALATION
NORMALLY NO PROBLEM, BUT INHALATION OF MIST COULD CAUSE RESPIRATORY
IRRITATION. MAY CAUSE SEVERE IRRITAITON OR BURNING OF THE MUCOUS
MEMBRANES OR DIGESTIVE TRACT IF INGESTED.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION, EYE BURNING, SKIN IRRITATION,
SKIN BURNING, RESPIRATORY TRACT IRRITATION, GI TRACT IRRITATION,
MUCOUS MEMBRANE IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH WITH SOAP AND WATER. IF IRRITATION PERSIST, GET MEDICAL
ATTENTION. INH ALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. GET
MEDICAL ATTENTION. INGESTION: DO NOT INDUCE VOMITING. GET MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:140F,60C
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE. WATER MAY BE
INEFFECTIVE BUT SHOULD BE USED TO KEEP FIRE EXPOSED CONTAINERS
COOL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR SELF CONTAINED
BREATHING APPARATUS AND FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UPON THERMAL
DECOMPOSITION. VAPORS ARE HEAVIER THAN AIR AND CAN FLOW TO A SOURCE
OF IGNITION.
================== Accidental Release Measures ==================
Spill Release Procedures:USE APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT
DURING CLEANUP. DIKE SPILL. PREVENT LIQUID FROM ENTERING SEWERS,
WATERWAYS OR LOW AREAS. SOAK UP WITH SAWDUST, SAND, OILDRY OR OTHER
ABSORBENT MATERIAL. S PILL MAY BE NEUTRALIZED WITH POWDERED SODIUM
BICAR
Neutralizing Agent:SODIUM CARBONATE.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID EYE AND SKIN CONTACT AND STORE
IN WELL-VENTILATED AREA. KEEP CONTAINER TIGHTLY CLOSED. DO NOT
STORE WITH INCOMPATIBLE MATERIALS.
Other Precautions:DO NOT STORE OR CONSUME FOOD, DRINK OR TOBACCO IN
AREA WHERE THEY MAY BECOME CONTAMINATED WITH THIS MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL CONDITIONS
Ventilation:ROOM VENTILATION (10 AIR CHANGES PER HOUR) IS SUFFICIENT.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
PRODUCT NOT EXPECTED TO PRESENT ANY SIGNIFICANT ECOLOGICAL PROBLEMS.
KEY1:C1.
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:=103.9C, 219.F
Vapor Pres:NOT GIVEN
Vapor Density:NOT GIVEN
Spec Gravity:1.088
pH:2 EST
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:AMBER SOLUTION, STRONG VINEGAR ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALI, OXIDIZERS
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OXIDES, CARBON DIOXIDE, CARBON
MONOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:RECOVER NONUSABLE FREE LIQUID AND/OR
CONTAMINATED WATER AND DISPOSE OF IN AN APPROVED AND PERMITTED
TREATMENT FACITILY.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: PROFESSIONAL LINE DAWN, 08536
Cage: DO549
=======================================================
Contractor Summary
=======================================================
Cage: PRCTR
Box: UNKNOW
Cage: DO549
Box: 599
=======================================================
Ingredients
=======================================================
Cas: 64-17-5
RTECS #: KQ6300000
OSHA PEL: 1000 PPM
ACGIH TLV: 1000 PPM
------------------------------
% Wt: 13
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Cas: 7732-18-5
RTECS #: ZC0110000
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INGESTION:MAY CAUSE TRANSIENT GASTROINTESTINAL IRRITATION.
SKIN:PROLONGED CONTACT WITH CONCENTRATED PRODUCT MAYBE DRYING OR IRRITATING
TO SKIN. EYE CONTACT.:MAY CAUSE STINGING, TEARING, ITCHING, SWELL ING AND/OR
REDNESS. SIGNS AND SYMPS:EXPECTED TO BE EMETIC IF INGESTED. MAY CAUSE NAUSEA
AND/OR DIARR. (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZS:MAY CAUSE MILD TRANSIENT
IRRITATION IF EYE CONTACT OCCURS. PROLONGED CONTACT WITH CONCENTRATED
MATERIAL MAY BE DRYING OR TRANSIENTLY IRRITATING TO SKIN.
Medical Cond Aggravated By Exposure: PRE-EXISTING DERMATITIS MAY BE AGGRAVATED
BY PROLONGED CONTACT WITH CONCENTRATED MATERIAL.
First Aid: INHALATION:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) (FP N). EYE CONTACT:FLUSH THOROUGHLY WITH WATER FOR AT LEAST 15
MINUTES. INGESTION:DRINK A GLASSFUL OF WATER. SKIN:IF PROLONGED C ONTACT
OCCURS, RINSE THOROUGHLY WITH WATER. IF SPILLED ON CLOTHING, CHANGE CLOTHES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: FLUSH SMALL QUANTITIES DOWN ACCEPTABLE SEWER
(CONTAINS BIODEGRADABLE SURFACTANTS). PREVENT SPILLS FROM REACHING WATERWAY.
SORBENTS MAY BE USED.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS (FP N). DISPOSAL IS TO BE PERFORMED IN COMPLIANCE WITH ALL
REGULATIONS. SMALL OR HOUSEHOLD QUANTITIES MAY BE DISPOSED OF IN SEWER. FOR
LARGER QUANTITIES INCIN IS PREFERRED. DO NOT LANDFILL.
Handling And Storage Precautions: NONE REQUIRED.
Other Precautions: DO NOT MIX WITH CHLORINE BLEACH AS TRANSIENT, IRRITATING
FUMES MAY RESULT. ALTHOUGH THIS PRODUCT HAS A FLASH POINT BELOW 200F (CLOSED
CUP) IT IS AN AQUEOUS SOLUTION CONTAINING ETHYL ALCOHOL AND DOES N OT SUSTAIN
COMBUSTION.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: CC
Flash Point Text: 90.0F,32.2C
Extinguishing Media: USE CO*2, WATER OR DRY CHEMICAL.
Fire Fighting Procedures: WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). NONE KNOWN.
Unusual Fire/Explosion Hazard: NONE KNOWN.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N). NONE REQUIRED WITH NORMAL USE.
Ventilation: LOCAL EXHAUST:NONE REQUIRED WITH NORMAL USE. MECHANICAL
(GENERAL):ACCEPTABLE.
Other Protective Equipment: ANSI APPROVED EMERGENCY EYE WASH AND DELUGE SHOWER
(FP N). NONE REQUIRED WITH NORMAL USE.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 1.03 (H*2O=1)
Solubility in Water: COMPLETE
Appearance and Odor: CLEAR BLUE UNSCENTED OR FLORAL SCENT OR CLEAN AMBER WITH A
LEMON SCENT LIQUID.
Percent Volatiles by Volume: 50
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE KNOWN.
Materials To Avoid: PRODUCTS CONTAINING CHLORINE.
Hazardous Decomposition Products: CHLORAMINES IN SMALL AMOUNTS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: PROFESSIONAL LINE DAWN, 08536
Cage: DO549
Assigned IND: Y
Company Name: PROCTER & GAMBLE FOODSERVICE & LODGING
Street: 6071 CENTER HILL RD-WINSTON HILL TECH CR
PO Box: 599
Zipcode: 45224
Label Required IND: Y
Date Of Label Review: 11/20/1996
Status Code: C
Label Date: 11/20/1996
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE. ACUTE:INGESTION:MAY CAUSE TRANSIENT
GASTROINTESTINAL IRRITATION. SKIN:PROLONGED CONTACT WITH CONCENTRATED PRODUCT
MAY BE DRYING OR IRRITATING TO SKIN. EYE CONTACT.:MAY CAUSE STINGING, TEARI
NG, ITCHING, SWELLING AND/OR REDNESS. SIGNS AND SYMPTOMS:EXPECTED TO BE
EMETIC IF INGESTED. MAY CAUSE NAUSEA AND/OR DIARRHEA. MAY CAUSE MILD
IRRITATION IF EYE CONTACT OCCURS. CHRONIC:PROLONGED CONTACT WITH
CONCENTRATED MATERIAL MAY BE DRYING OR TRANSIENTLY IRRITATING TO SKIN.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BENOX A-40P
Preparer's Name:ROBERT SUMMERS
CAGE:NORAC
CAGE:NORAC
============= Composition/Information on Ingredients =============
Ingred Name:BENZOYL PEROXIDE (SARA 313)
CAS:94-36-0
RTECS #:DM8575000
Fraction by Wt: 40%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3; 9495
Ingred Name:WATER (AS REPORTED BY MFR IN PRODUCT DESCRIPTION)
CAS:7732-18-5
RTECS #:ZC0110000
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS 7710 MG/KG
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:**POISON** EYES:MAY CAUSE
INFLAMMATION.SKIN:MAY CAUSE IRRITATION.INGEST:POISON BY
INGESTION.INHAL:NO HAZARDS REPORTED BY
MFR.CHRONIC:KIDNEY,URETER,TESTICULAR AND BLADDER
CHANGES,DERMATITIS,RESPIRATORY SENSITIZATION(ASTHMA),LOW BLOOD
PRESSURE(VASOLDILATION).
Explanation of Carcinogenicity:MFR STATES THAT MUTATION HAS BEEN
REPORTED REGARDING THE SUBJECT MATERIAL.
Effects of Overexposure:SKIN:REDNESS.INGEST:HALLUCINATIONS,DISTORTED
PERCEPTIONS,NAUSEA,VOMITING.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING
KIDNEY,URINARY SYSTEM OR RESPIRATORY AILMENTS MAY BE AT INCREASED
RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH SOAP AND
WATER.EYES:FLUSH WITH WATER FOR 15 MINUTES.SEEK MEDICAL
ATTENTION.INHAL:REMOVE TO FRESH AIR.GIVE OXYGEN OR ARTIFICIAL
RESPIRATION IF NEEDED.INGEST: DO NOT INDUCE VOMITING.GET PROMPT
QUALIFIED MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE WATER FOG AT A SAFE DISTANCE.FOR SMALL
FIRES,USE DRY CHEMICAL,CARBON DIOXIDE,FOAM.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.COOL FIRE EXPOSED CONTAINERS WITH WATER
FOG.
Unusual Fire/Explosion Hazard:**OXIDIZER** THIS MATERIAL,WHEN
DRY,SUPPLIES OXYGEN TO A FIRE.DECOMPOSITION PRODUCTS MAY BE TOXIC.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE SOURCES OF IGNITION.USE PROPER
RESPIRATORY AND PROTECTIVE EQUIPMENT.SHUT OFF LEAK IF
SAFE.DIKE.SOAK UP WITH A NON-COMBUSTIBLE INERT
ABSORBANT(CLAY,SAND);PLACE IN A DOT APPROVED CONTAINER FOR
DISPOSAL.WASH SPILL AREA TO REMOVE SLIPPINESS.
Neutralizing Agent:NOT REPORTED.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY,WELL-VENTILATED
PLACE.KEEP CONTAINER CLOSED WHEN NOT IN USE.KEEP AWAY FROM HEAT AND
INCOMPATIBLE MATERIALS.
Other Precautions:**PREVENT MATERIAL FROM GOING TO DRYNESS** AVOID SKIN
AND EYE CONTACT.DO NOT INHALE VAPORS/MISTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NEEDED IN NORMAL SERVICE.
Ventilation:NO SPECIAL REQUIREMENTS
Other Protective Equipment:PROTECTIVE CLOTHING,AS NEEDED.PROVIDE A
LOCAL EYE WASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS.SEPERATE WORK CLOTHES FROM STREET
CLOTHES.LAUNDER WORK CLOTHES BEFORE REUSE.KEEP FOOD OUT OF THE WORK
AREA.
Supplemental Safety and Health
**OXIDIZER(ESPECIALLY WHEN DRY) - POISON BY INGESTION**
================== Physical/Chemical Properties ==================
HCC:P1
Boiling Pt:B.P. Text:DECOMPOSES
Spec Gravity:1.1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:NOT REPORTED.HMIS NOTES THAT BENZOYL PEROXIDE IS A
SOLID;SPARINGLY WATER SOLUBL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HOT MATERIALS,PROMOTERS,ACCELERATORS,REDUCING
AGENTS(DIMETHYLANILINE,COBALT NAPTHENATE).
Stability Condition to Avoid:HIGH HEAT,SOURCES OF IGNITION,DRYING
CONDITIONS.
Hazardous Decomposition Products:CARBON DIOXIDE,CARBON MONOXIDE,BENZOIC
ACID,PHENYL BENZOATE,TERPHENYLS,BIPHENYLS,BENZENE.
Conditions to Avoid Polymerization:FIRE CONDITIONS MAY LEACH A
PLASTICIZER AWAY FROM BENZOYL PEROXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ACETONE
CAGE:5A188
CAGE:5A188
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 100.0%
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:CAUSES IRRITATION,REDNESS AND
TEARING OF EYES;SKIN:SLIGHT IRRITATION;INHALATION:NASAL,RESPIRATORY
IRRITATION,CNS
EFFECTS,DIZZINESS,WEAKNESS,FATIGUE,NAUSEA;G.I.IRRITATION.
CHRONIC:IN LAB ANIMALS, KIDNEY AND EYE DAMAGE.
Explanation of Carcinogenicity:NONE OF THE CHEMICALS IN THIS PRODUCT IS
LISTED BY IARC, NTP OR OSHA AS A CARCINOGEN.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF SKIN AND
RESPIRATORY DISORDERS MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:SKIN: THOROUGHLY WASH EXPOSED AREA WITH SOAP AND WATER.
REMOVE CONTAMINATED CLOTHING. LAUNDER CONTAMINATED CLOTHING BEFROE
RE-USE. EYES: FLUSH WITH LARGE AMOUNTS OF WATER. SEE DR. INGEST:
IMMEDIATELY DRINK TWO GLASSES OF WATER AND INDUCE VOMITING. SEE
DR. INHALE: REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT,
ADMINISTER OXYGEN. IF BREATHING STOPPED, GIVE ARTIFICIAL
RESPIRATION. SEE DR.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-1F,-18C
Lower Limits:2.6
Upper Limits:12.8
Extinguishing Media:ALCOHOL FOAM,CO*2,OR DRY CHEMICAL
Fire Fighting Procedures:SELF-CONT.BREATHING APPARTUS W/FULL FACE
PIECE(POS.PRESS.MOD
Unusual Fire/Explosion Hazard:FLASHBACK ALONG GROUND & IGNITED BY
IGNITION SOURCES.NEVER USE WELDING OR CUTTING ON OR NEAR DRUM.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILL:ABSORB LIQUID ON
PAPER,VEAMICULITE,FLOOR ABSORBEAT,OR OTHER ABSORBENT MATERIAL &
TRANSFER HOOD.LARGE SPILL:ELIMINATE ALL IGN.SOURCES;STOP SPILL AT
SOURCE,DIKE AREA OF SPILL,PUMP LIQ.TO SAL VAGE TK.REMAING LIQ.TAKEN
UP ON SAND,CLAY,EARTH
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTAINERS OF THIS MATERIAL MAY BE
HAZARDOUS WHEN EMPTIED.SINCE EMPTIED CONTAINERS RETAIN PRODUCT
RESIDUES(VAPOR,LIQUID,&/OR SOLID,ALL HAZARHOUS PRECA
Other Precautions:EXTREME CARE SHOULD BE TAKEN IN HANDLING THIS
MATERIAL,SINCE OVEREXPOSURE CAN CAUSE LIVER ABNORMALITIES,CENTRAL
NERVOUS SYSTEM DAMAGE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL (TLV), USE NIOSH/MSHA APPROVED RESPIRATOR AS
PER CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS AND
NIOSH-RESPIRATOR SELECTION.
Ventilation:MECHANICAL (GENERAL) VENTILATION IS REQUIRED. LOCAL EXHAUST
MAY BE REQUIRED IF WORK AREA IS NOT VENTED.
Other Protective Equipment:WEAR IMPERVIOUS CLOTHING &
Work Hygienic Practices:WASH THROUGHLY AFTER HANDLING AND BEFORE
EATING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:133F/56C
Vapor Pres:181.7
Vapor Density:2.0.
Spec Gravity:0.788
Evaporation Rate & Reference:14.4 (BU AC = 1)
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS;STRONG ALKALIES;STRONG MINERAL ACIDS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:CO*2,CO,NITROGEN COMPDS,VARIOUS
HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:125 8714 KODAK C TONER, GREEN
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:BUTYL ACRYLATE-P-DIVINYLBENZENE-STYRENE POLYMER/STYRENE
ACRYLATE COPOLYMER
CAS:57516-68-4
Fraction by Wt: 80-85%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ACRYLIC ACID BUTYL ESTER POLYMER WITH STYRENE/STYRENE
BUTYLACRYLATE COPOLYMER
CAS:25767-47-9
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:GREEN PHTHALOCYANINE PIGMENT
CAS:14302-13-7
Fraction by Wt: 3-7%
Other REC Limits:NONE RECOMMENDED
Ingred Name:BENZYLDIMETHYLOCTADECYLAMMONIUM
3-NITRO-BENZENESULFONATE/BENZENE METHANAMINE SALT
CAS:124088-59-1
Fraction by Wt: <2%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:KODAK DID NOT GIVE THIS INFO ON THE MSDS
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. EYES:NO SPECIFIC HAZARD KNOWN. MAY CAUSE
TRANSIENT IRRIT. SKIN:EXPECTED TO BE LOW HAZARD FOR RECOMMENDED
HANDLING. INGESTION:EXPECTED T O BE LOW INGESTION HAZARD.
Explanation of Carcinogenicity:IN ADDITION TO THE ABOVE, PRODUCT IS
NEGATIVE W/REGARD TO: ACGIH CANCER, CALIFORNIA CANCER &
REPRODUCTIVE EFFECTS.
Effects of Overexposure:TRANSIENT EYE IRRITATION.
Medical Cond Aggravated by Exposure:KODAK GAVE NO INFORMATION OF MSDS.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
OPEN. GET MEDICAL ATTENTION. SKIN:REMOVE CONTAMINATED CLOTHING.
WASH WITH SOAP AND WATER. IF IRRITATION PERSIST, GET MEDICAL
ATTENTION. INHAL ATION:REMOVE TO FRESH AIR. RESTORE BREATHING. GET
MEDICAL ATTENTION. INGESTION:DRINK 1-2 GLASSES OF WATER. GET
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE (CO2), DRY CHEMICAL.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:POWDERED MATERIAL MAY FORM EXPLOSIVE
DUST-AIR MIXTURES.
================== Accidental Release Measures ==================
Spill Release Procedures:DO NOT USE A VACUUM CLEANER TO CLEAN UP SPILLS
OF POWDERED TONERS. THE VERY FINE PARTICLES CAN CASUE A FIRE/
EXPLOSION. SWEEP MATERIAL ONTO PAPER AND PLACE IN FIBER CARTON.
CLEAN SURFACE THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
Neutralizing Agent:MFR GAVE NO INFORMATION OF MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED.
Other Precautions:AVOID BREATHING DUST. USE WITH ADEQUATE VENTILATION.
WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:USE GOOD GENERAL VENTILATION (TYPICALLY 4-6 ROOM
VOLUMES/HOUR). MATCH VENTILATION RATES TO CONDITIONS.
Other Protective Equipment:WASHING FACILITIES.
Work Hygienic Practices:EK: ? HIMIS: USE GOOD INDUSTRIAL HYGIENE
PRACTICES.MINIMIZE PERSONAL CONTACT. WASH THOROUGHLY AFTER
HANDLING.
Supplemental Safety and Health
KAN 471312, J-0600.030. THIS PRODUCT HAS NOT BEEN TESTED FOR
ENVIRONMENTAL EFFECTS.
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NONE
Vapor Pres:NEGLIGIBLE
Vapor Density:NEGLIGIBLE
Evaporation Rate & Reference:NEGLIGIBLE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:SOLID (POWDER), GREEN, SLIGHT ODOR.
Percent Volatiles by Volume:NEGLIG
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:STABLE UNDER NORMAL CONDITIONS OF USE.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE & NOX
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR LANDFILL. CAN BE INCINERATED WHEN
IN COMPLIANCE W/LOCAL REGULATIONS. DISCHARGE, TREATMENT, OR
DISPOSAL MAY BE SUBJECT TO NATIONAL, STATE OR LOCAL LAWS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ENDOSULFAN II (BETA) 25 MG,48578
CAGE:HO582
CAGE:54968
CAGE:HO582
============= Composition/Information on Ingredients =============
Ingred Name:BETA - ENDOSULFAN (SARA III)
CAS:33213-65-9
RTECS #:RB9875200
Other REC Limits:N/K
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 RAT ORAL 249 MG/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF INHALED OR SWALLOWED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES/SKIN:N/K .INGESTION/INHALATION:HARMFUL.
Medical Cond Aggravated by Exposure:N/K
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/ H*2O FOR AT LEAST 15 MIN.SKIN:FLUSH W/ LARGE
VOLUMES OF WATER.INGESTION:NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.NEVER TRY TO MAKE AN UNCONSCIOUS PERSON
VOMIT.INHALATION:IMM EDIATELY MOVE TO FRESH AIR.GIVE OXYGEN IF
BREATHING IS LABORED.CONTACT MD.
===================== Fire Fighting Measures =====================
Flash Point:N/K
Lower Limits:N/K
Upper Limits:N/K
Extinguishing Media:WATER,CO*2,DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:TOXIC VAPORS OF CHLORIDES AND SO*X ARE
FORMED WHEN THIS MATERIAL IS HEATED TO DECOMPOSITION.
================== Accidental Release Measures ==================
Spill Release Procedures:TAKE UP WITH ABSORBENT MATERIAL.AVOID
GENERATING DUST.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN SEALED CONTAINER IN COOL,DRY
LOCATION.AVOID GENERATING DUST.
Other Precautions:AVOID EYE OR SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW LEVEL OF CONCERN .
Work Hygienic Practices:N/K
Supplemental Safety and Health
ROUTES OF ENTRY:INHALATION/SKIN/INGESTION .
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:208C,406F
Decomp Temp:Decomp Text:N/K
Appearance and Odor:GRAYISH-WHITE POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CHLORIDES AND SO*X.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TYPE II WALKWAY NONSLIP B GRAY, G8868
CAGE:70228
CAGE:70228
============= Composition/Information on Ingredients =============
Ingred Name:HNDLG/STOR PREC: NEVER USE PRESSURE TO EMPTY, AVOID
BREATHING SANDING DUST.
RTECS #:9999999ZZ
Ingred Name:VENT: OSHA PERMISSIBLE EXP LIMIT OR ACGIH TLV LIMIT, &
VOLATILES BELOW LOWER EXPLOSIVE LIMIT. HEAVY SOLV (SEE INGRED 11)
RTECS #:9999999ZZ
Ingred Name:INGRED 10: VAP SHOULD BE REMOVED FROM LOWER LEVELS OF AREA,
& IGNITION SOURCES(NON-EXPLOSION PROOF EQUIP)(SEE INGRED 12)
RTECS #:9999999ZZ
Ingred Name:INGRED 11: SHOULD BE ELIMINATED IF FLAM MIX WILL BE
ENCOUNTERED. REMOVE DEOMP PROD FORMED DURING WELDING/(SEE INGRED
13)
RTECS #:9999999ZZ
Ingred Name:INGRED 12: FLAME CUTTING OF SURFS COATED W/PROD. FOR BAKING
FINISHES-VENT VAP EMITTED ON HEATING. HOT (SEE INGRED 14)
RTECS #:9999999ZZ
Ingred Name:INGRED 13: ORG CHEM VAP/MISTS ARE SUSCEPTIBLE TO SUDDEN
SPONT COMBUST WHEN MIXED W/AIR. IGNITION MAY (SEE INGRED 15)
RTECS #:9999999ZZ
Ingred Name:INGRED 14: OCCUR AT TEMPS BELOW THOSE PUBLISHED IN
LITERATURE AS "AUTOIGNITION" OR "IGNITION" TEMPERATURES.
RTECS #:9999999ZZ
Ingred Name:NAPHTHA, LIGHT ALIPHATIC (LIMITS AS VM & P NAPHTHA)
CAS:64742-89-8
Fraction by Wt: 20-50%
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 20-50%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:EXPLO HAZ: NOT BE IMMEDIATELY APPARENT. OBTAIN MED
ATTENTION.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: DRINK ONE TO TWO GLASSES OF WATER TO
DILUTE. INHAL: MOVE AFFECTED PERSON TO FRESH AIR. IF (SEE INGRED 5)
RTECS #:9999999ZZ
Ingred Name:INGRED 4: BREATHING IS DIFFICULT, ADMINISTER OXYGEN. IF
BREATHING HAS STOPPED, GIVE ARTF RESP. KEEP PERSON(SEE INGRED 6)
RTECS #:9999999ZZ
Ingred Name:INGRED 5: WARM, QUIET, AND GET MEDICAL ATTENTION. CONSULT
PHYS.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: -REMAINING LIQ MAY BE TAKEN UP W/SAND, FLOOR
ABSORB OR OTHER ABSORB MATL & SHOVELED INTO (SEE INGRED 8)
RTECS #:9999999ZZ
Ingred Name:INGRED 7: CONTRS-PVNT RUN-OFF TO SEWERS & BODIES OF
WATER-NOTIFY PROPER AUTHORITIES AS REQD BY LOCAL, STATE & FED REGS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: CAN CAUSE REDNESS, IRRIT,
SWELLING & BLURRED VISION. SKIN: PRLNGD/RPTD CONTACT CAN CAUSE
MODERATE IRRIT, DEFATTING, DERMATITIS. INHAL: EXCESSIVE INHAL OF
VAP &/OR SPRAY MIST CAN CAUSE RESP IRRIT , DIZZ, WEAKNESS, FATIGUE,
NAUSEA, HDCH,UNCONSCIOUSNESS & EVEN ASPHYXIATION. INGEST: CAN CAUSE
(SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA-CRYSTALLINE QUARTZ GROUP 2A
(IARC).
Effects of Overexposure:HLTH HAZ: GI IRRIT, NAUSEA, VOMITING &
DIARRHEA; ASPIR OF MATL INTO LUNGS CAN CAUSE CHEMICAL PNEUMONITIS
WHICH CAN BE FATAL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LRG AMOUNTS OF H2*O FOR AT LEAST 15 MIN. LIFT
EYELIDS OCCASIONALLY, GET PROMPT MED ATTN. SKIN: WASH THORO W/SOAP
& H2*O, REMOVE CONTAMD CLOTHING PROMPTLY; WASH CLOTHING BEFORE
REUSE. CON SULT PHYS IF IRRIT PERSISTS. INGEST: DON'T INDUCE VOMIT!
KEEP PERSON WARM, QUIET & GET MED ATTN. ASPIR OF MATL INTO LUNGS
DUE TO VOMIT CAN CAUSE CHEM PNEUMONITIS WHICH CAN BE FATAL. (SEE
INGRED 4)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:55.0F,12.8C
Lower Limits:1. %
Extinguishing Media:CARBON DIOXIDE,DRY CHEMICAL,FOAM,WATER FOG. USE
WATER FOR COOLING MATERIAL STORED IN VICINITY OF FIRE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . WEAR FULL PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:VAP ARE HVR THAN AIR & MAY TRAVEL ALONG
GROUND TO AN IGNITION SOURCE SOME DISTANCE FROM MATL HNDLG POINT.
IGNITION SOURCES INCLUDE PILOT LIGHTS, (SEE SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILL: ABSORB LIQ W/RAGS, FLOOR
ABSORBENT, VERMICULITE OR OTHER ABSORB MATL & TRANSFER TO HOOD. LRG
SPILL: ELIMINATE ALL IGNITION SOURCES-DIKE AREA OF SPILL TO PVNT
SPREADING-VENT AREA IF INDOOR S-PUMP LIQ INTO SALVAGE TANK-(SEE
INGRED 7)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T DROP CONTAINERS. AVOID HEAT,
SPARKS, & OPEN FLAME. STORE LRGE QTYS ONLY IN BUILDINGS DESIGNED TO
COMPLY W/OSHA 1910.106. (SEE INGRED 9)
Other Precautions:CAUTION: PRODUCT CONTAINS PIGMENTS WHICH MAY BECOME A
DUST NUISANCE WHEN REMOVED BY SANDING, ABRADING OR SANDBLASTING.
DUST MASKS SHOULD BE WORN DURING THESE OPERATIONS TO AVOID THIS
HAZARD.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN OUTDOOR/OPEN AREAS W/UNRESTRICTED VENT
NIOSH/MSHA APPRVD CHEM/MECHANICAL FILTERS DESIGNED TO REMOVE A
COMBINATION OF PARTICULATES & VAPOR. IN CONFINED AREAS, NIOSH/MSHA
APPRVD AIR LINE TYPE RESPIRA TORS OR HOODS.
Ventilation:PROVIDE SUFFICIENT VENT IN VOLUME & PATTERN TO KEEP AIR
CONTAM CONCENTRATION BELOW CURRENT APPLICABLE (SEE INGRED 10)
Other Protective Equipment:NORMAL PROTECTIVE CLOTHING. WASH
CONTAMINATED CLOTHING BEFORE REUSE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ: SMOKING, HEATERS, ELECTRIC MOTORS, SPARKS FROM ELEC SWITCHES
& STATIC DISCHARGES. CAUTION: NEVER USE CUTTING TORCH ON EMPTY
CNTNRS! RESIDUAL SOLV VAP IN EMPTY CNTNR MAY EXPLODE. APPLICATN T O
HOT SURFS REQS SPEC PREC. DURING EMERGENCY CNDTNS, OVEREXP TO
DECOMP PROD MAY CAUSE HLTH HAZ. SYMP MAY (SEE INGRED 3)
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:246F,119C
Vapor Density:HVR/AIR
Spec Gravity:1.38
Evaporation Rate & Reference:1.04 (BUTYL ACETATE=1)
Appearance and Odor:LIQUID PAINT.
Percent Volatiles by Volume:49.6%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZERS (E.G. NITRIC ACID)
Stability Condition to Avoid:KEEP AWAY FROM HEAT AND OPEN FLAME.
Hazardous Decomposition Products:MAY FORM CARBON MONOXIDE AND DIOXIDE.
VARIOUS HYDROCARBONS, ETC.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:V-1107 BROWN SILICONE PASTE
CAGE:5D028
CAGE:5D028
CAGE:71984
============= Composition/Information on Ingredients =============
Ingred Name:NO HAZARDOUS MATERIALS PRESENT
===================== Hazards Identification =====================
Effects of Overexposure:MAY CAUSE TEMPORARY DISCOMFORT TO EYES
======================= First Aid Measures =======================
First Aid:FLUSH W/WATER
===================== Fire Fighting Measures =====================
Flash Point:>250 F OC
Extinguishing Media:CO*2 OF FOAM
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:MOP,WIPE OR SOAK UP WITH ABSORBENT MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:NOTHING SPECIAL
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Ventilation:MECHANICAL GENERAL RECOMMENDED
Other Protective Equipment:AS REQUIRED
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>300F
Vapor Pres:<5
Spec Gravity:1.0
Evaporation Rate & Reference:<1,ETHER
Solubility in Water:<0.1%
Appearance and Odor:PASTE LIKE,VERY LITTLE ODOR
Percent Volatiles by Volume:<5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Hazardous Decomposition Products:SIO*2,CO*2,TRACES OF INCOMPLETELY
BURNED CARBON PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CAN BE LANDFILLED OR BURNED IN ACCORDANCE WITH
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MIL-P-24441/4C F-153 BLACK, COMP A
Kit Part:Y
Preparer's Name:H KLINE
CAGE:0Y2E4
CAGE:55849
CAGE:0Y2E4
============= Composition/Information on Ingredients =============
Ingred Name:MAGNESIUM SILICATE
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: <45%
Other REC Limits:NONE SPECIFIED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:BUTYL ALCOHOL (SARA III) (CERCLA) (VAPOR PRESSURE 4.3 MM HG
@ 68F) (ORAL LD50 2.5 G/KG RAT; INHALE LC50 8000 PPM RAT)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 32.20%
Other REC Limits:* STEL 50 PPM (SKIN)
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:POLYAMIDE ADDUCT RESIN
Fraction by Wt: <25%
Other REC Limits:NONE SPECIFIED
Ingred Name:AMIDO AMINE RESIN (ORAL LD50 1.2 G/KG RAT)
CAS:68443-08-3
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:XYLENE (SARA III) (VAPOR PRESSURE 6.6 MM HG @ 68F) (ORAL
LD50 4.3 G/KG RAT; INHALE LC50 6700 PPM RAT)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 1.32%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/STEL 150 PPM
ACGIH TLV:100 PPM/STEL 150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TRIETHYLENE TETRAMINE (ORAL LD50 2.5 G/KG RAT)
CAS:112-24-3
RTECS #:YE6650000
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
Ingred Name:VOC: 337 G/L, 2.8 LBS/GAL
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:ACUTE; VAPOR HARMFUL. EYE, SKIN, NOSE,
THROAT IRRIT. INHALE: HEADACHE, NAUSEA, DIZZY. HARMFUL IF
SWALLOWED. HARMFUL IF INHALED/ABSORBED THRU SKIN. BLOOD, CNTRL
NERVOUS SYS DAMAGE. INGEST: LUNG, KIDNEY /LIVER DAMAGE. SKIN/EYE
BURNS/INJURY. SKIN/RESPIRATORY SENSITIZATION (RASH, HIVES, ASTHMA).
CHEM PNEUMONIA. ASPIRATN HZD
Effects of Overexposure:CHRONIC; REPEATED AND PROLONGED OCCUPATIONAL
OVEREXPOSURE TO SOLVENT IS ASSOCIATED WITH PERMANENT BRAIN AND
NERVOUS SYSTEM DAMAGE.
Medical Cond Aggravated by Exposure:RESPIRATORY. ALLERGIES. KIDNEY AND
LIVER DISORDERS. SKIN. EYES.
======================= First Aid Measures =======================
First Aid:OVEREXPOSURE TO VAPOR/SPRAY MIST - GIVE FRESH AIR. IF
BREATHING LABORED, GIVE OXYGEN/ARTIFICIAL RESPIRATION. SKIN: WASH
THOROUGHLY WITH SOAP & WATER. EYES: FLUSH IMMEDIATELY WITH PLENTY
OF WATER FOR A T LEAST 15 MINUTES.GET MEDICAL ATTENTION.
INGESTION: DRINK 1 OR 2 GLASSES OF WATER TO DILUTE. DO NOT INDUCE
VOMITING. CONSULT PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY.
TREAT SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:99.0F,37.2C
Autoignition Temp:Autoignition Temp Text:650F
Lower Limits:1.00
Upper Limits:11.20
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT, SELF-CONTAINED
BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINER MAY EXPLODE WHEN EXPOSED
TO EXTREME HEAT. ISOLATE FROM HEAT/IGNITION SOURCE. PREVENT STATIC
DISCHARGE. VAPORS SPREAD LONG DISTANCES, FLASHBACK.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID BREATHING OF VAPORS. USE ABSORBENT
CLEANUP MATERIALS. PLACE IN SEPARATE CONTAINERS. KEEP OUT OF SEWERS
AND WATERWAYS. IF ENTRY IS THREATENED OR OCCURS, NOTIFY LOCAL
AUTHORITIES. ELIMINATE ALL SO URCES OF IGNITION.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED, UPRIGHT WHEN
NOT IN USE. STORE IN COOL, DRY, WELL VENTED AREA. AVOID STORAGE AT
TEMPERATURES ABOVE 100 F. DONT TAKE INTERNALLY.
Other Precautions:AVOID PROLONGED BREATHING OF VAPORS OR SPRAY MIST OR
CONTACT WITH SKIN & EYES. DESTROY CONTAMINATED LEATHER AND
ABSORBENT SHOES WHICH CANNOT BE DECONTAMINATED. DO NOT WELD OR
FLAME CUT EMPTY CONTAINER . GROUND CONTAINERS WHEN POURING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA CERTIFIED RESPIRATOR. FOR SPECIFIC
CONDITIONS, REFER TO NIOSH POCKET GUIDE TO CHEMICAL HAZARDS. USE
AIR-LINE RESPIRATORS IN CONFINED OR RESTRICTED VENTILATION AREAS.
REFER TO 29 CFR OSHA PA RTS 1910 & 1915 FOR COATING OPERATIONS.
Ventilation:KEEP AIR CONTAMINANT CONCENTRATIONS BELOW TLV. REMOVE
WELDING/FLAME CUTTING DECOMPOSITION PRODUCTS. SEE 29CFR 1910/1915.
Other Protective Equipment:FULL PROTECTIVE CLOTHING. SPARK PROOF
EQUIPMENT.
Work Hygienic Practices:WASH THOROUGHLY BEFORE EATING, SMOKING OR USING
WASHROOM. WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:244 TO 276F
Vapor Density:> AIR
Viscosity:>68 KU
Evaporation Rate & Reference:(BU AC=1) 0.50 TO 0.60
Appearance and Odor:LIQUID. SOLVENT ODOR
Percent Volatiles by Volume:52
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS, ALKALIES. EPOXIES UNDER UNCONTROLLED
CONDITIONS.
Stability Condition to Avoid:HEAT, OPEN FLAME, ARC OR SPARKS.
Hazardous Decomposition Products:CO AND CO2. NOX. TOXIC GASES OR FUMES.
Conditions to Avoid Polymerization:HEAT, OPEN FLAME, ARC, SPARKS.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN SEPARATE, CLOSED METAL CONTAINER IN
ACCORDANCE WITH ALL APPLICABLE REGULATIONS. EPA WASTE NO: D001,
D002.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BROCO WHITE PORTLAND
CAGE:SUTHD
CAGE:SUTHD
============= Composition/Information on Ingredients =============
Ingred Name:PORTLAND CEMENT
CAS:65997-15-1
RTECS #:VV8770000
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:TRICALCIUM SILICATE; (3*CAO-SIO*2) (CALCIUM SALT)
CAS:12168-85-3
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DICALCIUM SILICATE; (2*CAO-SIO*2) (CALCIUM SALT)
CAS:10034-77-2
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TRICALCIUM ALUMINATE; (3*CAO-AL*2O*3) (CALCIUM SALT)
CAS:12042-78-3
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TETRACALCIUM ALUMINOFERRATE; (4*CAO-AL*2O*3-FE*2O*3)
(CALCIUM SALT)
CAS:12068-35-8
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:GYPSUM; (CASO*4-2*H*2O) (CALCIUM SALT)
CAS:13397-24-5
RTECS #:MG2360000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:MAGNESIUM OXIDE (MGO)
CAS:1309-48-4
RTECS #:OM3850000
OSHA PEL:10 MG/M3 RESP
ACGIH TLV:10 MG/M3 FUME
Ingred Name:POTASSIUM SULFATE (2:1); (K*2SO*4)
CAS:7778-80-5
RTECS #:TT5900000
Fraction by Wt: TRACE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM SULFATE (2:1); (NA*2SO*4)
CAS:7757-82-6
RTECS #:WE1650000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:WET CEMENT, ESPECIALLY AS AN
INGREDIENT IN PLASTIC (UNHARDENED) CONCRETE, CAN DRY SKIN & CAUSE
ALKALI BURNS. CEMENT DUST CAN IRRITATE EYES & UPPER RESPIRATORY
SYSTEM. CHRONIC:CEMENT DUST CAN CAU SE INFLAMMATION OF LINING
TISSUE OF EYE. HYPERSENSITIVE INDIVIDUALS MAY DEVELOP AN ALLERGIC
DERMATITIS (SKIN RASH).
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . EYES:IRRIGATE W/WATER FOR
AT LEAST 15 MINUTES; CONSULT MD. SKIN:WASH EXPOSED AREAS W/SOAP &
WATER.
===================== Fire Fighting Measures =====================
Flash Point:NON COMBUSTIBLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:USE DRY CLEANUP METHODS THAT DO NOT DISPERSE
DUST INTO AIR.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PRECAUTIONS MUST BE OBSERVED BECAUSE
WET CEMENT BURNS W/LITTLE WARNING - LITTLE HEAT IS SENSED.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN DUSTY ENVIRONMENTS, USE A NIOSH/MSHA APPROVED
RESPIRATOR.
Ventilation:USE EXHAUST FANS TO CONTROL AIRBORNE DUST LEVELS.
Other Protective Equipment:ANSI APVD EMERGENCY EYE WASH & DELUGE SHOWER
. USE BARRIER CREAMS, BOOTS & CLOTHING TO PROTECT SKIN FROM
(SUPDAT)
Work Hygienic Practices:IMMEDIATELY AFTER WORKING W/CEMENT, WORKERS
SHOULD SHOWER W/SOAP & WATER.
Supplemental Safety and Health
OTHER PROT EQUIP:PROLONGED CONTACT W/WET CEMENT, ESPECIALLY IN PLASTIC
(UNHARDENED) CONCRETE.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:2.85-3.2
Solubility in Water:SLIGHT (0.1-1%)
Appearance and Odor:GRAY OR WHITE POWDER; NO ODOR.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:KEEP DRY UNTIL USED.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . MATERIAL CAN BE RETURNED TO CONTAINER FOR LATER USE,
OR IT CAN BE DISPOSED OF AS A COMMON WASTE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MINIT OFF PAINT REMOVER
CAGE:HO854
CAGE:85519
CAGE:HO854
============= Composition/Information on Ingredients =============
Ingred Name:METHYLENE CHLORIDE(SARA III)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 66.5%
OSHA PEL:500 PPM/C,1000; Z2
ACGIH TLV:50 PPM, A2; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PARAFFIN WAX
CAS:8002-74-2
RTECS #:RV0350000
Fraction by Wt: 2.5%
OSHA PEL:2 MG/M3 (FUME)
ACGIH TLV:2 MG/M3 (FUME); 9192
Ingred Name:HYDROXYPROPYL CELLULOSE (KLUCEL H)
CAS:9004-64-2
RTECS #:NF9050000
Fraction by Wt: .5%
Ingred Name:VM & P NAPHTHA (VAPOR PRESSURE 2.0)
CAS:64742-48-9
RTECS #:SE7555000
Fraction by Wt: 7.2%
Other REC Limits:LEL 1.1
ACGIH TLV:300 PPM
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 10.0%
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:ETHYL ALCOHOL (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 9.0%
Other REC Limits:LEL 3.3
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9192
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 3.9%
Other REC Limits:LEL 6.7
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPANOLAMINE PRG
CAS:78-96-6
RTECS #:UA5775000
Fraction by Wt: .4%
Ingred Name:DYE. OIL BROWN
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:DIZZINESS, FAINTING SPELLS. SKIN
CONTACT, WILL BECOME RED WITH IRRITATION.
Effects of Overexposure:DIZZINESS, FAINTING SPELLS. SKIN CONTACT, WILL
BECOME RED WITH IRRITATION.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF SKIN AND
RESPIRATORY DISORDERS MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE SUBJECT TO FRESH AIR. EYE: FLUSH WITH
PLENTY OF WATER FOR 15 MINUTES. GET IMMEDIATE MEDICAL ATTENTION.
SKIN: WASH WITH SOAP AND WATER. INGESTION: DO NOT INDUCE VOMITING.
GET IMMEDIA TE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:118 F/ 48 C
Extinguishing Media:DRY POWDER, CO2 OR WATER.
Fire Fighting Procedures:CONFINED LIQUID IN DRUMS EXPOSED TO HIGH
TEMPERATURES WILL RUPTURE DUE TO HIGH INTERNAL PRESSURE.
Unusual Fire/Explosion Hazard:KEEP DRUMS COOLED WITH WATER SPRAY.
================== Accidental Release Measures ==================
Spill Release Procedures:WASH OFF WITH WATER, VENTILATE AREAS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE MATERIAL IN COOL AREAS.
Other Precautions:OPEN BUNGS SLOWLY TO RELEASE PRESSURE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE IN WELL VENTILATED AREAS.
Ventilation:THOROUGH AIR VENTILATION AT FLOOR LEVEL.
Other Protective Equipment:RUBBER APRON
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:103F,39C
Vapor Density:> THAN AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:73
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:OPEN FLAME.
Hazardous Decomposition Products:EXPOSED TO OPEN FLAME FORMS HYDROGEN
CHLORIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:STORE DEPLEATED MATERIAL IN OPEN TOP DRUM, DUMP
DISPOSAL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:186 2192 EKTAPRINT2 DEVLR PARTB (ITEM DISCONT NSN CANCE94005
Kit Part:Y
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 80 - 85%
Other REC Limits:NONE SPECIFIED
Ingred Name:HYDROXYLAMINE SULFATE
CAS:10039-54-0
RTECS #:NC5425000
Fraction by Wt: 10 - 15%
Other REC Limits:NONE SPECIFIED
Ingred Name:LITHIUM CHLORIDE
CAS:7447-41-8
RTECS #:OJ5950000
Fraction by Wt: 5 - 10%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MAY CAUSE IRRITATION. SKIN: MAY
BE HARMFUL IF ABSORBED THROUGH THE SKIN. PROLONGED OR REPEATED
CONTACT MAY CAUSE SKIN IRRITATION. MAY CAUSE AN ALLERGIC SKIN
REACTION. INHALATION: LOW HAZARD FOR RECOMMENDED HANDLING.
INGESTION: MAY BEHARMFUL IF SWALLOWED.
Explanation of Carcinogenicity:THIS PRODUCT CONTAINS NO INGREDIENT
LISTED AS CARCINOGEN BY IARC, NTP, OR OSHA.
Effects of Overexposure:EYES: IRRITATION. SKIN: IRRITATION AND AN
ALLERGIC SKIN REACTION. INHALATION: POSSIBLE IRRITATION OF UPPER
RESPIRATORY TRACT. INGESTION: POSSIBLE IRRITATION OF G.I.TRACT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. GET MEDICAL
ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. FLUSH AREA WITH
LARGE AMOUNTS OF WATER. GET MEDICAL ATTENTION IF SYMPTOMS PERSIST.
INHALATION: MOVE TO FRESH AIR. GET MEDICAL ATTENTION IF SYMPTOMS
PERSIST. INGESTION: INDUCE VOMITING IMMEDIATELY AS DIRECTED BY
MEDICAL PERSONNEL. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING TO PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILLS: FLUSH SPILL TO SEWER WITH LARGE
AMOUNTS OF WATER. LARGE SPILLS: ABSORB SPILL WITH INERT MATERIAL
AND PLACE IN A CONTAINER FOR PROPER DISPOSAL. FLUSH RESIDUAL SPILL
AND AREA WITH WATER.PR EVENT UNDILUTED SPILL RUNOFF FROM ENTERING
DRAINS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY AND WELL
VENTILATED AREA. PROTECT CONTAINERS FROM PHYSICAL DAMAGE. KEEP FROM
CONTACT WITH OXIDIZING MATERIALS.
Other Precautions:AVOID BREATHING VAPORS OR MIST. AVOID CONTACT WITH
EYES, SKIN, OR CLOTHING. WASH THOROUGHLY AFTER HANDLING. USE
VENTILATION THAT IS ADEQUATE TO KEEP EMPLOYEE EXPOSURE TO AIRBORNE
CONCENTRATIONS BELOW RECOMMENDED EXPOSURE LIMITS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATORS ARE NOT NEEDED FOR NORMAL HANDLING.
SUPPLEMENTARY RESPIRATORY PROTECTION MAY BE NEEDED IN SPECIAL
CIRCUMSTANCES.
Ventilation:GOOD VENTILATION (10 ROOM VOL/HR) SHOULD BE
SUFFICIENT.SUPPLEMENTARY VENTILATION MAY BE NEEDED IN SPECIAL
CIRCUMSTANCES.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER. CLOTHING
TO MINIMIZE SKIN EXPOSURE.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
KEY1:C3. THIS ENTRY DESCRIBES EKTAPRINT 2 DEVELOPER, PART B, P/N IND H
OF 7 PART KIT. EACH PART-B UNIT YIELDS 3.5 GAL. OF SOLUTION. SEE
THIS NSN FOR DATA ON OTHER 6 PARTS OF KIT.
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.11
pH:2.9
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID. ODORLESS.
Percent Volatiles by Volume:82
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES AND FLAMES
Hazardous Decomposition Products:MAY PRODUCE NITROGEN AND HYDROGEN
CHLORIDE GAS.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS. THIS SOLUTION IS STRONGLY ACIDIC, BUT AFTER DILUTION
AND SECONDARY TREATMENT IS NOT EXPECTED TO HAVE ANY ADVERSE
ENVIRONMENTAL IMPACT.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:39492; LITHIUM MANGANESE (IV) OXIDE (SUPDAT)
CAGE:JO569
CAGE:JO569
============= Composition/Information on Ingredients =============
Ingred Name:LITHIUM MANGANESE (IV) OXIDE
CAS:12163-00-7
Fraction by Wt: BALANCE
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:LITHIUM OXIDE
CAS:12057-24-8
Fraction by Wt: 10-25%
Ingred Name:SUPDAT:EYE CONTACT:NONE KNOWN. INHAL:CHRONIC INHALATION OF
MAGANESE DUST MAY CAUSE CHRONIC MANGANESE POISONING (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:WHICH INVOLVES IMPAIRMENT OF THE CNS. SYMPTOMS
INCLUDE SLUGGISHNESS, SLEEPINESS AND WEAKNESS IN THE LEGS. (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:ADVANCED CASES HAVE SHOWN FIXED FACIAL EXPRESSIONS,
EMOTIONAL DISTURBANCES, SPASTIC GAIT AND FALLING. (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:OTHER:CHRONIC MAGANESE POISONING MAY DEVELOP AFTER AS
LITTLE AS THREE MONTHS OF HEAVY EXPOSURE BUT (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:USUALLY CASES DEVELOP AFTER ONE TO THREE YEARS OF
EXPOSURE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INGEST:INGEST OF LARGE AMOUNTS
OF LITHIUM ION MAY CAUSE VOMITING, DIARRHEA, ATAXIA, INTESTINAL
IRRITATION, KIDNEY INJURY, CNS DEPRESSION & DROP IN BLOOD PRESSURE.
CNS EFFECTS MAY INCLUDE SLURRE D SPEECH, BLURRED VISION, DIZZINESS,
SENSORY LOSS, CONVULSIONS AND STUPOR. SKIN CONTACT:NONE KNOWN.
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:EYE CNTCT:MAY CAUSE IRRIT. INHAL:NONE
KNOWN. OTHER HLTH HAZ:LITHIUM OXIDE REACTS W/MOIST TISS TO FORM
LITHIUM HYDROXIDE, WHICH CAUSES CAUSTIC BURNS.
CHRONIC:INGEST:INTAKE OF LITHIUM ION MAY C AUSE NEUROMSCULAR EFTS
SUCH AS TREMOR, ATAXIA, WEAK, CLONUS & HYPERACTIVE REFLEXES.
LITHIUM ION CAN CAUSE (SUPDAT)
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INGEST:GIVE LRG QTIES OF H*2O/MILK IF AVAIL. CALL A MD IMMED.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERS. SKIN
CNTCT:REMOVE CONTAMD CLTHG, FLOOD SKIN W/LRG AMTS OF H*2O. IF IRRIT
PERSISTS SEE K MED ATTN. EYE CNTCT:IMMED FLUSH EYES,INCL UNDER
EYELIDS, W/LRG AMTS OF H*2O FOR AT LEAST 15 MIN. CALL A MD.
INHAL:REMOVE TO FRESH AIR. IF NOT BREATHING GIVE ARTF RESP. CALL A
MD IMMED.
===================== Fire Fighting Measures =====================
Extinguishing Media:NON-FLAMMABLE. USE ANY MEANS SUITABLE FOR
SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . IF WITHOUT RISK REMOVE MATERIAL FROM FIRE AREA.
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:WEARING FULL PROTECTIVE EQUIPMENT, COVER SPILL
WITH DRY SAND OR VERMICULITE. MIX WELL AND CAREFULLY TRANSFER TO A
CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN A COOL, DRY, WELL-VENTILATED AREA.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED DUST MASK.
Ventilation:LABORATORY FUME HOOD.
Other Protective Equipment:ANSI APPRVD EMER EYE WASH & DELUGE SHOWER .
LAB COAT AND APRON. FLAME AND CHEMICAL RESISTANT COVERALLS.
Work Hygienic Practices:WASH THOROUGHLY AFTER USE.
Supplemental Safety and Health
MFR'S TRADE NAME PART #:(CONTAINS 10-25% LITHIUM OXIDE). EFTS OF
OVEREXP:KIDNEY DMG, GI DISTURB, FATIGUE, DEHYDRATION, WEIGHT LOSS,
DERMATOLOGICAL EFTS & THRYOID DISTURB. LITHIUM ION HAS SHOWN
TERATOG ENIC EFTS IN RATS & MICE. RPTD INGEST OF MANGANESE
COMPOUNDS MAY CAUSE LETHARGY & EDEMA. SKIN CNTCT:NONE KNOWN. (ING
3)
================== Physical/Chemical Properties ==================
Appearance and Odor:RED POWDER, ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:INCOMPATIBLES.
Hazardous Decomposition Products:LITHIUM HYDROXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT STATE, LOCAL OR FEDERAL EPA REGULATIONS
FOR PROPER DISPOSAL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ECO MOTOR OIL SAE 102-30, CPS222427
CAGE:81230
CAGE:2H740
CAGE:81230
============= Composition/Information on Ingredients =============
Ingred Name:SEVERELY HYDROTREATED PETROLEUM HYDROCARBON BASE
STOCK;(SEVERLY HYDROTREATED LUB OIL, SPENT)
CAS:64742-58-1
Fraction by Wt: >80.0%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ADDITIVES (INCLUDING ING 3)
Fraction by Wt: <20%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ZINC ALKYL DITHIOPHOSPHATE; (PHOSPHORODITHOIC ACID,
O-O-DI-CL-14-ALKYL ESTERS, ZINC SALTS)
CAS:68649-42-3
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:FIRST AID PROC: BREATHING(GIVE O*2/ARTF RESP).
RTECS #:9999999ZZ
Ingred Name:SUPP DATA: RELEASES. NOT EXPECTED TO CAUSE ENVIRONMENTAL
PROBLEMS OTHER THAN THOSE ASSOC W/OIL SPILLS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NOT EXPECTED TO CAUSE SIGNIFICANT
EYE/SKIN IRRIT. SHOULD BE PRACTICALLY NON-TOXIC TO INTERNAL ORGANS
IF INHAL, EYES, ON SKIN/INGESTED. PROD CONTAINS ZINC ALKYL
DITHIOPHOSPHATES(ZDDPS). SEVERAL ZDDPS H AVE BEEN REPORTED TO HAVE
WEAK MUAGENICACTIVITY IN CULTURED MAMMALIAN CELLS BUT ONLY AT CONCS
TOX TO(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: TEST CELLS. THIS PROD CONTAINS
PETROLEUM BASE OILS WHICH MAY BE REFINED BY VARIOUS PROCESSES INCLG
SEVERE SOLV EXTRACTION, SEV HYDROCRACKING/SEV HYDROTREATING. DURING
USE IN ENGINES, CONTAM OF OIL W/LOW LEVELS OF CANCER-CAUSING
COMBUST PRODS OCCURS. USED MOTOR OILS HAVE BEEN SHOWN TO CAUSE SKIN
CANCER(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH EYES W/FRESH WATER FOR AT LEAST 15 MINS. REMOVE
CONT LENSES IF WORN. SKIN:AS PREC, WASH SKIN THORO W/SOAP & WATER.
REMOVE & WASH CONTAMD CLTHG. INGEST:GIVE WATER/MILK TO DRINK &
MD ADVICE CANNOT BE OBTAINED, THEN TAKE PERS & PROD CNTNR TO
NEAREST MED EMER TREATMENT CENTER/HOSP. INHAL:REMOVE TO FRESH AIR.
SUPPORT(ING 4)
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>392F,>200C
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:NORMAL COMBUSTION FORMS CARBON DIOXIDE,
WATER VAPOR & MAY PRODUCE OXIDES OF SULFUR & NITROGEN. INCOMPLETE
COMBUSTION CAN PRODUCE CARBON MONOXIDE.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP SOURCE OF LEAK/RELEASE. CLEAN UP RELEASES
AS SOON AS POSSIBLE. CONTAIN LIQUID TO PREVENT FURTHER CONTAM OF
SOIL, SURFACE WATER/GROUNDWATER. CLEAN UP SMALL SPILLS USING APPROP
TECHNIQUES SUCH AS S ORBENT MATLS/PUMPING. WHERE FEASIBLE &
(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT USE/STORE NEAR FLAME,
SPARKS/HEATED SURFS. DO NOT WELD, HEAT/DRILL CNTNR. RESIDUE MAY
IGNIT W/EXPLOS VIOLENCE IF HEATED SUFF.
Other Precautions:CAUTION! DO NOT USE PRESSURE TO EMPTY DRUM OR DRUM
MAY RUPTURE WITH EXPLOSIVE FORCE. AVOID PROLONGED/FREQUENT REPEATED
SKIN CONTACT W/THIS MATL. SEE CHEVRON MSDS #1793 FOR ADDITIONAL
INFORMATION ON US ED MOTOR OIL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL RESPIRATORY PROTECTION IS NORMALLY
REQUIRED. HOWEVER, IF OPERATING CONDITIONS CREATE HIGH AIRBORNE
CONCENTRATIONS, THE USE OF A NIOSH/MSHA APPROVED RESPIRATOR IS
RECOMMENDED.
Ventilation:USE ADEQUATE VENTILATION TO KEEP THE AIRBORNE
CONCENTRATIONS OF THIS MATERIAL BELOW THE RECOMMENDED EXPOSURE
STANDARD.
Other Protective Equipment:SKIN CONTACT CAN BE MINIMIZED BY WEARING
PROTECTIVE CLTHG.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:IN MICE FOLLOWING RPTD APPLIC & CONTINUOUS EXPOS.
BRIEF/INTERMITTENT SKIN CONT W/USED MOTOR OIL IS NOT EXPECTED TO
HAVE SERIOUS EFTS IN HUMANS IF OIL IS THORO REMOVED BY WASHING
W/SOAP & WATER. SPILL PROC:APPROP, REMOVE CONTAMD SOIL. FOLLOW
PRESCRIBED PROCS FOR REPORTING & RESPONDING TO LARGER (ING 5)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:<572F,<300C
Vapor Pres:<.01 @ 20C
Spec Gravity:0.88
Solubility in Water:INSOLUBLE
Appearance and Odor:BROWN, OILY LIQUID WITH PETROLEUM ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY REACT W/STRONG OXIDIZING AGENTS, SUCH AS CHLORATES, NITRATES,
PEROXIDES, ETC.
Stability Condition to Avoid:DO NOT HEAT ABOVE FLASH POINT.
Hazardous Decomposition Products:CARBON MONOXIDE & ASPHYXIANTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE CONTAMD MATLS IN DISP CNTNRS & DISP OF IN
MANNER CONSISTENT W/APPLIC REGS. CONTACT LOCAL, STATE & FEDERAL
ENVIRONMENTAL/HEALTH AUTHORITIES FOR APPROVED DISP OF THIS
MATERIAL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:120 4247, EKTACHEM CLINICAL CHEMISTRY CALIBRATOR KIT 6, CAL2
Kit Part:Y
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 100% %
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): NOT GIVEN
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. EXPECTED TO BE A LOW EYE CONTACT HAZARD.
EXPECTED TO BE A LOW SKIN CONTACT HAZARD. EXPECTED TO BE A LOW
INGESTION HAZARD.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:NONE SPECIFIED BY MANUFACTURER.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:NONFLAMMABLE. USE STANDARD FIREFIGHTING
PROCEDURES FOR SURROUNDING MATERIALS IN THE FIRE.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. STORE AT OR
BELOW 0F.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.00
pH:7.0
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR COLORLESS LIQUID, NO ODOR
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE WITH COMMON MATERIALS AND CONTAMINANTS WITH WHICH THE MATERIAL MAY
REASONABLY COME INTO CONTACT.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. FLUSH TO SEWER WITH LARGE
AMOUNTS OF WATER.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:MS-2000 HARDENER COMPONENT
Kit Part:Y
Preparer's Name:ERNEST CARTER
CAGE:88444
CAGE:88444
============= Composition/Information on Ingredients =============
Ingred Name:POLYAMIDE/EPOXY ADDUCT
CAS:68424-41-9
Code:F
Minumum % Wt:60.
Maxumum % Wt:70.
Ingred Name:AMIDOAMINE RESIN
CAS:68443-08-3
Code:F
= Wt:16.
Ingred Name:1-METHOXY-2-PROPANOL
CAS:107-98-2
RTECS #:UB7700000
Minumum % Wt:10.
Maxumum % Wt:25.
ACGIH TLV:369 MG/M3;100 PPM
ACGIH STEL:553 MG/M3;150 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:EYES: CAUSES SEVERE IRRITATION OR
BURNS, MAY CAUSE PERMANENT VISUAL IMPAIRMENT. SKIN: CAUSE SEVERE
IRRITATION OR BURNS, MAY BE ABSORBED THROUGH SKIN IN HARMFUL
AMOUNTS. INHALATION: MAY CAUSE UPPER RE SPIRATORY TRACT
IRRITATION. INGESTION: MAY CAUSE BURNS OF MOUTH AND THROAT.
CONTAINS MATERIAL THAT MAY BE SLIGHTLY TOXIC.
Effects of Overexposure:IRRITATION, SENSITIZATION AND DERMATITIS.
Medical Cond Aggravated by Exposure:ALLERGY, ECZEMA AND OTHER SKIN
CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE QUANTITIES OF WATER FOR AT LEAST 15
MINUTES. SKIN: REMOVE CONTAMINATED CLOTHING. WASH CONTACT AREA WITH
MILD SOAP AND WATER. INHALATION: REMOVE TO FRESH AIR. IF SYMPTOMS
PERSIST CONSULT A PHYSICIAN. INGESTION: DO NOT INDUCE VOMITING. IF
CONSCIOUS, GIVE LARGE QUANTITIES OF WATER TO DILUTE.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:=37.8C, 100.F
Extinguishing Media:DRY CHEMICAL, CHEMICAL FOAM, CARBON DIOXIDE OR
WATER.
Fire Fighting Procedures:REMOVE ALL SOURCES OF IGNITION. WEAR COMPLETE
PERSONAL PROTECTION EQUIPMENT INCLUDING SELF-CONTAINED BREATHING
APPARATUS WHERE POTENTIAL FOR EXPOSURE TO VAPORS OR PRODUCTS OF
COMBUSTION EXISTS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY RUPTURE (DUE TO
BUILD UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. DIKE. ABSORB
WITH INERT MATERIAL AND COLLECT FOR DISPOSAL. FLUSH CONTAMINATED
AREA WITH DILUTE 5% ACETIC ACID AND COLLECT RINSATE FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:GROUND AND BOND METAL CONTAINERS FOR
LIQUID TRANSFER TO AVOID STATIC SPARKS.
Other Precautions:A SAFETY SHOWER AND EYE WASH FACILITY SHOULD BE
AVAILABLE TO EMPLOYEES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR WITH ORGANIC
VAPOR CARTRIDGE IF REQUIRED.
Ventilation:EXPLOSION PROOF MECHANICAL VENTILATION AND LOCAL EXHAUST
RECOMMENDED. MECHANICAL EXHAUST SHOULD NOT BE THE SOLE MEANS OF
CONTROLLING EMPLOYEE EXPOSURE.
Other Protective Equipment:IN OPERATIONS WHERE CONTACT MAY OCCUR
COVERALLS, APRON ANDIMPERVIOUS FOOT COVERING ARE RECOMMENDED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:0.96
Solubility in Water:PARTIALLY SOLUBLE
Appearance and Odor:AMBER LIQUID, SOLVENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
OXIDES OF NITROGEN.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A LICENSED HAZARDOUS WASTE
FACILITY IN ACCORDANCE WITH APPLICABLE LAWS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:INSTANT ACTIVATOR 141-001
CAGE:JO863
CAGE:JO863
CAGE:61803
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
OSHA PEL:C, 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SODIUM SULFITE
CAS:7757-83-7
RTECS #:WE2150000
Ingred Name:POTASSIUM CARBONATE
CAS:584-08-7
RTECS #:TS7750000
Ingred Name:SODIUM PHOSPHATE, TRIBASIC(SARA III)
CAS:7601-54-9
RTECS #:TC9490000
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CAUSES SEVERE BURNS.
Effects of Overexposure:EYES:SEVERE BURNS.POSSIBLE PERMANENT TISSUE
DAMAGE AND POSSIBLE BLINDNESS. SKIN:SEVERE IRRITATION.POSSIBLE
CHEMICAL BURNS AND POSSIBLE PERMANENT TISSUE DAMAGE.
INGESTION:HARMFUL IF SWALLOWED.
Medical Cond Aggravated by Exposure:DERMATITIS MAY BE AGGRAVATED.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MIN.SEE DOCTOR. SKIN:REMOVE CONTAMINATED CLOTHING & SHOES.FLUSH
WITH LARGE AMOUNTS OF WATER UNTIL SLIPPERY FEEL IS GONE,AT LEAST 15
MIN. IF IRRIT ATION IS EVIDENT,SEE DOCTOR. INHALATION:REMOVE TO
FRESH AIR.GIVE OXYGEN/CPR IF NEEDED. INGESTION:DO NOT INDUCE
VOMIT.GIVE WATER AND MILK.SEE DOCTOR IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:AS APPROPIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
AND PROTECTIVE CLOTHING.ABSORB LIQUID IN INERT ABSORBENT AND PLACE
IN APPROPIATE DISPOSAL CONTAINERS.WASH AREA WITH LARGE AMOUNTS OF
WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY PLACE.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:NORMAL ROOM VENTILATION.
Other Protective Equipment:APRON. EYE WASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
SMOKING OR EATING.LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NONE.
================== Physical/Chemical Properties ==================
HCC:B1
Boiling Pt:>100.C, 212.F
Spec Gravity:1.2
pH:14
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR,COLORLESS LIQUID. NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG MINERAL ACIDS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:SULFUR DIOXIDE AND CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:NOTIFY YOUR LOCAL ENVIRONMENTAL OFFICER. DISPOSE
OF IN ACCORDANCE WITH ALL APPLICABLE FEDERAL,STATE AND LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: 960-3475 PANTONE 347 GREEN EXTRA LATITUDE INK 5 LBS
Cage: 0FTL5
Proprietary Ind: Y
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 0FTL5
=======================================================
Contractor Summary
=======================================================
Cage: 0FTL5
Cage: 09177
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES: MAY CAUSE BURNING & IRRITATION. SKIN: MAY CAUSE
IRRITATION/DERMATITIS. INGESTION: MAY CAUSE IRRITATION.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: IRRITATION, BURNING, HEADACHE, DIZZINESS,
DROWSINESS, NAUSEA, GASTRIC DISTURBANCE.
Medical Cond Aggravated By Exposure: SKIN DISORDERS/DERMATITIS.
First Aid: EYES: RINSE THOROUGHLY W/WATER FOR 15 MINS. SKIN: WASH W/MILD SOAP
& WATER. INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED.
INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN AL L CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: WIPE UP W/RAGS. DISPOSE OF RAGS IN CONTAINERS
APPROVED FOR OILY WASTE.
Waste Disposal Methods: DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
Handling And Storage Precautions: KEEP CONTAINERS CLOSED WHEN NOT IN USE. KEEP
AWAY FROM EXCESSIVE HEAT, SPARKS, OPEN FLAMES. FOR COMMERCIAL/INDUSTRIAL USE
ONLY.
Other Precautions: DON'T REUSE CONTAINER. KEEP FROM REACH OF CHILDREN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point Text: >200F
Extinguishing Media: FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures: WATER MAY BE INEFFECTIVE, BUT CAN BE USED TO COOL
CONTAINERS EXPOSED TO HEAT/FLAME. FOG NOZZLES ARE PREFERABLE IF WATER IS
USED.
Unusual Fire/Explosion Hazard: DENSE SMOKE MAY BE GENERATED WHILE BURNING.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT NORMALLY REQUIRED.
Ventilation: GENERAL AS PER LOCAL REGULATIONS.
Other Protective Equipment: APRON, BOOTS, IMPERVIOUS CLOTHING
Work Hygienic Practices: WASH THOROUGHLY AFTER HANDLING.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >200F
Vapor Pres: 0.1
Vapor Density: >1
Spec Gravity: <1
Solubility in Water: INSOLUBLE
Appearance and Odor: GREEN PASTE W/OILY ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: EXCESS HEAT, SPARKS, OPEN FLAME.
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: BY FIRE: DENSE SMOKE & CO.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: 960-3475 PANTONE 347 GREEN EXTRA LATITUDE INK 5 LBS
Cage: 0FTL5
Company Name: AM MULTIGRAPHICS
Street: 1800 WEST CENTRAL ROAD
Zipcode: 60056
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: EYES: BURNING & IRRITATION. SKIN:
PROLONGED/REPEATED EXPOSURE MAY CAUSE IRRITATION/DERMATITIS. INGESTION:
IRRITATION. MAY AFFECT THE CNS & RESPIRATORY SYSTEM.
BURNING,
IRRITATION, HEADACHE, DIZZINESS, DROWSINESS, NAUSEA, GASTRIC DISTURBANCE.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ALKYD, SEMI-GLOSS INTERIOR YELLOW 23711
Preparer's Name:FRED ARMSTRONG
CAGE:33832
CAGE:33832
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 29%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9293
Ingred Name:VOC=3.10 LBS/GAL OR 372 GRAMS/LITER
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Health Hazards Acute and Chronic:OVEREXPOSURE-NAUSEA, HEADACHE,
DIZZINESS CAUSED BY OVER INHALATION. HIGH VAPOR CONCENTRATIONS
(>1000 PPM) ARE IRRITATING TO THE EYES AND RESPIRATORY TRACT, ARE
ANESTHETIC, AND MAY HAVE OTHER CENTRAL N ERVOUS SYSTEM EFFECTS.
Effects of Overexposure:OVEREXPOSURE-NAUSEA, HEADACHE, DIZZINESS CAUSED
BY OVER INHALATION. HIGH VAPOR CONCENTRATIONS (>1000 PPM) ARE
IRRITATING TO THE EYES AND RESPIRATORY TRACT, ARE ANESTHETIC, AND
MAY HAVE OTHER CENTRAL N ERVOUS SYSTEM EFFECTS.
Medical Cond Aggravated by Exposure:NONE GENERALLY KNOWN.
======================= First Aid Measures =======================
First Aid:EYE CONTACT: FLUSH WITH WATER 15 MINUTES OR UNTIL IRRITATION
SUBSIDES. IF IRRITATION PERSISTS, CALL PHYSICIAN. SKIN CONTACT:
REMOVE CONTAMINATED CLOTHING AND WASH THOROUGHLY WITH SOAP AND
WATER. INHAL ATION: IF OVERCOME BY VAPORS REMOVE TO FRESH AIR, CALL
PHYSICIAN. INGESTION: DO NOT INDUCE VOMITING, CALL PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:103 F/40 C
Autoignition Temp:Autoignition Temp Text:473 F
Lower Limits:0.9
Upper Limits:7
Extinguishing Media:CARBON DIOXIDE, FOAM, WATER FOG OR DRY CHEMICAL.
Fire Fighting Procedures:USE AIR SUPPLIED BREATHING EQUIPMENT. COOL
ENCLOSED CONTINERS WITH WATER SPRAY. AVOID BREATHING VAPORS OR
FUMES..
Unusual Fire/Explosion Hazard:IF LEAK OR SPILL HAS IGNITED, USE WATER
SPRAY TO DISPERSE THE VAPORS FROM FIRE FIGHTERS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. KEEP FROM HEAT,
SPARKS AND OPEN FLAME. ADD ABSORBENT (SAND, EARTH, SAWDUST) TO
SPILL. VENTILATE AREA (OPEN WINDOWS, DOORS). LARGE SPILL: KEEP FROM
ENTERING SEWERS/WATERCOU RSES BY DIKING. ADVISE AUTHORITIES IF DOES
ENTER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM IGNITION SOURCES, KEEP
IN COOL, DRY, WELL VENTILATED AREAS. AVOID DIRECT SUNLIGHT AND
EXTREME TEMPERATURES, HOT OR COLD.
Other Precautions:AVOID EYE, SKIN CONTACT, INHALATION &/OR INGESTION OF
MISTS, SPRAY OR VAPORS. AVOID BREATHING SANDING OR BLASTING DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE HYDROCARBON VAPOR CANISTER OR SUPPLIED AIR
RESPIRATOR IN CONFINED AREAS.
Ventilation:LOCAL EXHAUST: FACE VELOCITY 60FPM. SPECIAL: USE ONLY
W/ADEQUATE VENTILATION. MECHANICAL: USE EXPLOSION PROOF EQUIPMENT.
Other Protective Equipment:USE CHEMICAL RESISTANT APRON OR CLOTHING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:308F,153C
Melt/Freeze Pt:M.P/F.P Text:0 F(-17.8C)
Decomp Temp:Decomp Text:600 F(316C)
Vapor Pres:<10 @ 68 F
Vapor Density:4.8 @ 77 F
Spec Gravity:1.34 (H2O=1)
Viscosity:77-89@77FKREB
Evaporation Rate & Reference:0.09 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:YELLOW LIQUID WITH KEROSENE ODOR.
Percent Volatiles by Volume:50.2
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CAN REACT WITH OXIDIZING MATERIAL WHEN HEATED TO DECOMPOSITION.
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:ASSURE CONFORMITY WITH APPLICABLE DISPOSAL
REGULATIONS. DISPOSE OF ABSORBED MATERIAL AT AN APPROVED DISPOSAL
SITE OR FACILITY. DISPOSE IN CONFORMITY WITH STATE AND FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:RECYCLED LATEX PAINT
Preparer's Name:RAY JULIAN
CAGE:TO169
CAGE:TO169
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA III)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 1-3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:50 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICA, CRYSTALLINE
CAS:14464-46-1
RTECS #:VV7325000
Fraction by Wt: 10-20%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:0.05 MG/M3
Ingred Name:VOC: LESS THAN 250 G/L
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED/REPEATED OVEREXPOSURE TO
HIGH CONCENTRATIONS OF RESPIRABLE (AIRBORNE) CRYSTALLINE SILICA
DUSTS (GENERATED BY SANDING/GRINDING DRIED PAINTS/OTHER BUILDING
MATERIALS W/O WEARING PROPER RESPRTR Y PROTECTION) CAN CAUSE
SILICOSIS, NON-CANCEROUS LUNG DISEASE-CAN RESULT IN SUBSTANTIAL
IMPAIRMENT OF BREATHING FUNCTION
Effects of Overexposure:DIZZINESS, HEADACHE, NAUSEA, CONFUSION,
IRRITATION TO UPPER RESPIRATORY TRACT, SKIN & EYE IRRITATION.
Medical Cond Aggravated by Exposure:SEE YOUR PHYSICIAN FOR SPECIFIC
MEDICAL OPINION REGARDING YOUR CONDITION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. CONSULT
PHYSICIAN. EYE: FLUSH WITH LARGE VOLUMES OF WATER FOR 15 MINUTES.
GET MEDICAL ATTENTION. SKIN CONTACT: WIPE OFF WITH A RAG. WASH
THOROUGHLYWITH SOAP AND WATER. INGESTION: CONSULTHOSPITAL
EMERGENCY ROOM OR POISON CONTROL CENTER IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:>200F,>93C
Extinguishing Media:N/R * 8.5
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO THE
BUILD-UP OF STEAM PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA TO PREVENT BUILD-UP OF VAPORS.
FOR SMALL SPILLS, SOAK UP WITH ABSORBENT. FOR LARGE SPILLS, DIKE
AREA WITH ABSORBENT MATERIAL AND SCOOP UP LIQUIDS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE UPRIGHT IN SEALED CONTAINERS
AWAY FROM HEAT AND FLAME.
Other Precautions:REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE PARTICLE MASK (NIOSH/MSHA TC-21C) TO AVOID
BREATHING SPRAY MIST/SANDING DUST. LOCAL VENT ADEQUATE TO KEEP
VAPOR CONCENTRATIONS W/IN ACCEPTABLE (TLV) LIMITS. IF LOCAL VENT
NOT SUFFICIENT OR WHERE L EL EXCEEDED WEAR FITTED TC-23C OR BETTER
Ventilation:LOCAL CROSS VENT OR MECHANICAL EXHAUST SUFFICIENT TO KEEP
ALL HAZARDOUS VAPOR CONCENTRATIONS BELOW PRESCRIBED LIMITS.
Supplemental Safety and Health
CONTAINS PIGMENTS SUCH AS MINERAL SILICATES,SILICON DIOXIDE & TITANIUM
DIOXIDE.NOT HAZARDOUS IN WET PAINT,BUT MAY REACH HAZARDOUS LEVELS
IN DUST FROM SANDING/GRINDING DRIED PAINT.LIKE MOST NATURAL OCC
URING MINERALS,PIGMENTS CONTAIN SOME CRYSTALLINE SILICA-IARC
DETERMINED LIMITED EVIDENCE FOR CARCINOGENICITY IN HUMANS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Vapor Density:< AIR
Spec Gravity:1.25-1.35 H20=1
pH:7.5- *
Viscosity:80-100 KU
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:VARIOUS COLORS
Percent Volatiles by Volume:60-70
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO DECOMPOSITION AS IN WELDING.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARD IN LANDFILL IN SEALED METAL CONTAINERS
AWAY FROM HEAT AND FLAME AND IN ACCORDANCE WITH LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:RP-1250 HARDENER
Kit Part:Y
CAGE:02684
CAGE:02684
============= Composition/Information on Ingredients =============
Ingred Name:DIETHYLENE TRIAMINE
CAS:111-40-0
RTECS #:IE1225000
OSHA PEL:1 PPM
ACGIH TLV:S, 1 PPM; 9192
Ingred Name:CALCIUM CARBONATE (MARBLE) (LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
Other REC Limits:PEL:5MG/M3 RESP FRAC
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9192
Ingred Name:ALUMINUM (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 30%
Other REC Limits:PEL:5MG/M3 RESP FRAC
OSHA PEL:15MG/M3 DUST/5 FUME
ACGIH TLV:10MG/M3 DUST; 9192
Ingred Name:FUMED SILICA
CAS:112945-52-5
RTECS #:VV7310000
OSHA PEL:6 MG/M3 AIR TWA
ACGIH TLV:10 MG/M3 (TDUST)
Ingred Name:4,4'-ISOPROPYLIDENEDIPHENOL (SARA III)
CAS:80-05-7
RTECS #:SL6300000
Fraction by Wt: 1.66%
Ingred Name:TRIETHYLENE TETRAMINE (TETA) (PENNSYLVANIA RIGHT-TO-KNOW
ACT)
CAS:112-24-3
RTECS #:YE6650000
Ingred Name:ALUMINUM OXIDE TRIHYDRATE (HYDRATED ALUMINA)
CAS:21645-51-2
RTECS #:BD0940000
OSHA PEL:15 MG/M3 (TDUST)
ACGIH TLV:10 MG/M3 (TDUST)
Ingred Name:NONYL PHENOL
CAS:25154-52-3
RTECS #:SM5600000
Ingred Name:FATTY ACIDS, C18 UNSATURATED, DIMERS, REACTION PRODUCTS
WITH POLYETHYLENE POLYAMINES (POLYETHYLENE AMIDO AMINES)
CAS:68410-23-1
Ingred Name:1,3-BENZENEDIMETHANAMINE (AMINE ADDUCT)
CAS:68738-77-2
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Health Hazards Acute and Chronic:SKIN: IRRITANT. EYE: CORROSIVE. CAUSES
BURNS. SENSITIZATION: POSSIBLE IN SUSCEPTIBLE INDIVIDUALS. SKIN
IRRITATION. CAUSES ALLERGIC SKIN AND RESPIRATORY REACTIONS.
Medical Cond Aggravated by Exposure:SKIN AND EYE CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATLEY FLUSH EYES WITH WATER FOR AT LEAST 15
MINUTES. CALL A PHYSICIAN. SKIN: WASH WITH SOAP AND WATER. REMOVE
CONTAMINATED CLOTHING AND LAUNDER BEFORE RE-USE. INGESTION: IF
CONSCIOUS, GIVE PLENTY OF WATER TO DRINK. DO NOT INDUCE VOMITING.
CALL A PHYSICIAN. INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN
AND/OR CPR, IF NEEDED, CALL A PHYSICIAN. REFER TO PHYSICIAN IF ANY
INJURY QUESTIONS.
===================== Fire Fighting Measures =====================
Flash Point:>200F,>93C
Extinguishing Media:CARBON DIOXIDE, FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:DECOMPOSITION AND COMBUSTION PRODUCTS MAY
BE TOXIC.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SPILLAGE BY ABSORBING IN ABSORBENT
MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:CORROSIVE. EYE BURNS & SKIN
IRRITATION. ALLERGIC/RESPIRATORY REACTION. AVOID CONTACT
W/SKIN/CLOTHING. AVOID PROLONGED/REPEATED CONTACT WITH SKIN.
Other Precautions:NUISANCE DUST MAY BE GENERATED WHEN SANDING OR SAWING
CURED MATERIAL. HARMFUL IF ABSORBED THROUGH SKIN. DO NOT GET IN
EYES. KEEP CONTAINER CLOSED. USE WITH ADEQUATE VENTILATION. WASH
THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE AMINE ORGANIC CARTRIDGE VAPOR RESPIRATOR, IF
NEEDED.
Ventilation:GENERAL MECHANICAL AND LOCAL EXHAUST IN ACCORDANCE WITH
ACGIH RECOMMENDATIONS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Pres:< 0.1
Spec Gravity:1.59 - 1.66
Solubility in Water:SLIGHT
Appearance and Odor:DARK GRAY PASTE, WITH AMMONIACAL ODOR.
Percent Volatiles by Volume:<1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS AND BASES.
Stability Condition to Avoid:EXCESSIVE HEAT FOR PROLONGED PERIODS OF
TIME.
Hazardous Decomposition Products:COMBUSTION MAY FORM TOXIC MATERIALS,
SUCH AS CARBON DIOXIDE, CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT QUALIFIED LOCAL OR CORPORATE PERSONNEL
FOR METHOD THAT WILL COMPLY WITH LOCAL, STATE AND FEDERAL HEALTH
AND ENVIRONMENTAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CESIUM CHLORIDE, 813700
CAGE:IO030
CAGE:30060
CAGE:IO030
============= Composition/Information on Ingredients =============
Ingred Name:CESIUM CHLORIDE
CAS:7647-17-8
RTECS #:FK9625000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC:MODERATE ORAL TOXICITY.
CAN CAUSE EYE IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING. RINSE LIBERALLY WITH WATER
FOR A CONSIDERABLE PERIOD. INGEST:IF WITHIN 15 MINUTES AFTER
OCCURENCE, MAKE PATIENT DRINK 1 OR 2 GLASSES OF WATER. EYES:RINSE
LIBERALLY W ITH WATER FOR AT LEAST 15 MINUTES. INHAL:TAKE THE
PATIENT INTO THE FRESH AIR AND ALLOW TO REST.
===================== Fire Fighting Measures =====================
Flash Point:NOT AVAILABLE
Extinguishing Media:USE EXTINGUISHING MEDIA SUITABLE FOR SURROUNDING
FIRE .
Fire Fighting Procedures:NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP INTO SUITABLE CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:2377F,1303C
Melt/Freeze Pt:M.P/F.P Text:1195F,646C
Spec Gravity:3.99
Solubility in Water:SOLUBLE
Appearance and Odor:POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BF*3
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF C1-
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR LANDFILL AS COMPLIES WITH FEDERAL,
STATE AND LOCAL LAWS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HSF, HI-SPEED NEUTRAL CLEANER
CAGE:59972
CAGE:59972
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPANOL
CAS:67-63-0
RTECS #:NT8050000
= Wt:3.
OSHA PEL:980 MG/M3;400 PPM
ACGIH TLV:983 MG/M3;400 PPM
ACGIH STEL:1230 MG/M3;500 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: CONTACT MAY BE SLIGHTLY
IRRITATING. SKIN: REPEATED CONTACT MAY BE IRRITATING. INGESTION:
MAY BE HARMFUL. INHALATION: NOT CONSIDERED A HAZARD. ACUTE HEALTH
EFFECT: NONE. CHRONIC HEALTH EFFECTS: N ONE.
Explanation of Carcinogenicity:MANUFACTURER'S MSDS STATES: CARCINOGEN:
NO.
Effects of Overexposure:IEYES: IRRITATION. SKIN: IRRITATION.
======================= First Aid Measures =======================
First Aid:SKIN: REMOVE CONTAMINATED CLOTHING. WASH EXPOSED AREAS WITH
WATER. IF IRRITATION PERSISTS GET MEDICAL ATTENTION. EYES: WASH
WITH LARGE VOLUMES OF WATER FOR AT LEAST 15 MINUTES WHILE LIFTING
THE UPPER AND LOWER EYELIDS AND ROTATING THE EYEBALL. GET MEDICAL
ATTENTION IF IRRITATION PERSISTS. INGESTION: GIVE LARGE VOLUMES OF
WATER. DO NOT INDUCE VOMITING. GET MEDICAL ATTENTION. INHALATION:
N/A.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:N/A. (WILL NOT BURN).
Unusual Fire/Explosion Hazard:FIRE FIGHTERS SHOULD OBSERVE ALL
PRECAUTIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:FLOOD AREA WITH WATER. MOP UP, DISPOSE TO
SANITARY SEWER. ABIDE BY FEDERAL, STATE, AND LOCAL REGULATIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN TIGHTLY CLOSED CONTAINERS.
STORE CONTAINERS IN AN UPRIGHT POSITION. DO NOT DESTROY OR DEFACE
THE LABEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Ventilation:NONE REQUIRED
Other Protective Equipment:NONE REQUIRED
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:0.974 (H2O= 1.0)
pH:7.0
Solubility in Water:COMPLETE
Appearance and Odor:GREEN LIQUID; FLORAL ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NONE KNOWN.
=================== Toxicological Information===================
Toxicological Information:NONE
===================== Ecological Information =====================
Ecological:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:ABIDE BY FEDERAL, STATE AND LOCAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:DOT TRANSPORT INFORMATION: THIS PRODUCT IS NOT
REGULATED.
===================== Regulatory Information =====================
SARA Title III Information:THIS PRODUCT CONTAINS THE FOLLOWING TOXIC
CHEMICALS SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF
THE EMERGENCY PLANNING AND COMMUNITY RIGHT-TO-KNOW ACT OF 1986 AND
OF 40 CFR 372: NONE.
Federal Regulatory Information:ALL INGREDIENTS APPEAR ON THE TSCA
INVENTORY LIST.
State Regulatory Information:
======================= Other Information =======================
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:CONTECH CONCRETE CRACK PATCH, 73-951
CAGE:CHEMR
CAGE:CHEMR
CAGE:53024
============= Composition/Information on Ingredients =============
Ingred Name:CLAY (KAOLIN); (KAOLIN CLAY)
CAS:1332-58-7
RTECS #:GF1670500
Fraction by Wt: 1-5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: MILD IRRITANT. NO
PERMANENT CORNEAL INJURY LIKELY. SKIN: MILD IRRITANT. MAY CAUSE
DEFATTING AND REDNESS. INHALATION: MAY CAUSE IRRITATION OF
RESPIRATORY TRACT. INGESTION: MAY CAUSE NAUSEA AND VOMITING. NO
SPECIFIC EFFECTS KNOWN. CHRONIC: THIS PRODUCT CONTAINS ENCAPSULATED
KAOLIN (CLAY). (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: NO EXPOSURE TO RESPIRABLE CLAY IS
ANTICIPATED DURING NORMAL USE OF THIS PRODUCT. OCCUPATIONAL
OVEREXPOSURE TO KAOLIN CLAY OVER MANY YEARS MAY CAUSE PULMONARY
FIBROSIS. THIS DISEASE MAY EXIST WITH OR WITHOUT IMPAIRMENT IN
LUNG FUNCTION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINUTES. OBTAIN
IMMED MED ATTN. SKIN: REMOVE CONTAM CLTHG. WASH AFFECTED AREA(S)
THOROUGHLY W/SOAP & WATER. CONSULT MD. INHAL: REMOVE TO FRESH AIR.
IF BRT HG IS DFCLT, GIVE OXYGEN. ADMIN ARTF RESP IF NOT BRTHG.
OBTAIN MED ATTN. INGEST: INDUCE VOMIT IF CONSCIOUS & NOT DROWSY.
GIVE WATER OR MILK IF CONSCIOUS & NOT DROWSY. SHOULD VOMITING
OCCUR, (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:DOES NOT FLASH
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE . DOES NOT
SUSTAIN FLAME.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . WILL NOT SUSTAIN FLAME.
Unusual Fire/Explosion Hazard:IRRITATING AND/OR TOXIC GASES OR FUMES
MAY BE GENERATED BY THERMAL DECOMPOSITION.
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA. WEAR APPROP PROT EQUIP DURING
CLEANUP. CONTAIN SPILL. ABSORB W/INERT MATERIAL SUCH AS
VERMICULITE. PLACE INTO CNTNRS W/LIDS. COVER LOOSELY & REMOVE TO
APPROP WASTE AREA. WASH SPILL AREA. PR EVENT WASHINGS FROM ENTERING
WATERWAYS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT TAKE INTERNALLY. AVOID CONTACT
WITH EYES, SKIN & CLOTHING. WASH THOROUGHLY AFTER HANDLING. TIGHTLY
RESEAL ALL PARTIALLY USED CONTAINERS.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF THE TLV IS EXCEEDED, IF USE IS PERFORMED IN A
POORLY VENTILATED CONFINED SPACE OR AREA WITH LIMITED VENTILATION,
USE NIOSH APPROVED ORGANIC VAPOR CARTRIDGE RESPIRATOR IN ACCORDANCE
WITH 29 CFR 1910 .134.
Ventilation:LOCAL EXHAUST AS NEEDED TO CONTROL VAPOR/DUST LEVELS TO
BELOW RECOMMENDED LIMITS.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
CLEAN PROTECTIVE CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EVAP RATE: SLOWER (RELATIVE TO N-BUTYL ACETATE). SOL IN H*2O:
APPRECIABLE (10.0-99.9%). FIRST AID PROC: BE SURE TO KEEP VICTIM'S
HEAD BELOW HIPS TO AVOID ASPIRATION OF VOMITUS INTO LUNGS. OBTAIN
IMMED MED ATTN.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Vapor Pres:17.5 @ 20C
Vapor Density:LTR/AIR
Spec Gravity:1.72
Evaporation Rate & Reference:SUPDAT
Solubility in Water:SUPDAT
Appearance and Odor:THICK PASTE WITH LITTLE ODOR.
Percent Volatiles by Volume:30
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES OR OXIDANTS. STRONG LEWIS OR MINERAL ACIDS.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:ACRID FUMES. OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:REVIEW ALL LOCAL, STATE AND FEDERAL REGULATIONS
CONCERNING HEALTH AND POLLUTION FOR APPROPRIATE DISPOSAL
PROCEDURES.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:02112 URSA SUPER PLUS SAE 30
CAGE:38431
CAGE:38431
CAGE:7B131
============= Composition/Information on Ingredients =============
Ingred Name:DIALKYLDITHIOPHOSPHORIC ACID: ZINC SALT
CAS:68649-42-3
Fraction by Wt: 1-3.99%
Other REC Limits:NOT KNOWN
OSHA PEL:NOT KNOWN
ACGIH TLV:NOT KNOWN
Ingred Name:SOLVENT-DEWAXED HEAVY PARRAFFINIC PETROLEUM DISTILLATES
CAS:64742-65-0
RTECS #:PY8038500
Fraction by Wt: 80-94.9%
Other REC Limits:NOT KNOWN
OSHA PEL:NOT KNOWN
ACGIH TLV:NOT KNOWN
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL:BLIEVD TO BE >5G/KG (RAT) (SUP DAT)
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES-BELIEVED TO BE MINIMALLY
IRRITATING.SKIN-BELIEVED TO BE MINIMALLY IRRITATING.RESP
SYSTEM-BELIEVD TO BE MIN IRRI IF NOT IN EXCESS OF PERMISS
CONC.CHRONIC:SKN-USED MOTOR OILS HVE CAUS SKN CAN CER IN LAB ANIM
WHN REPEA APPLIED & LEFT IN PLAC BTWEEN APPLICATIONS.
Explanation of Carcinogenicity:NOT APPLICABLE
Effects of Overexposure:SEE HEALTH HAZARD SECTION .
Medical Cond Aggravated by Exposure:NOT KNOWN .
======================= First Aid Measures =======================
First Aid:EYE:FLUSH IMME W/LGE AMTS OF WTR FOR AT LEAST 15
MIN.SKIN:PROMPTLY WASH THOROUGHLY W/SOAP & WTR.INGESTION:CALL MD
IMMED .INHALATION:RMV FROM EXPOSURE. SUPPORT BREATHING (GIVE
O*2/ART IFICIAL RESPIRATION).
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:430F/221.11C
Lower Limits:N/DETERMINED
Upper Limits:N/DETERMINED
Extinguishing Media:ACCORD TO NFPA GUIDE;USE WTR SPRY;DRY
CHEM;FOAM;/CO*2.WTR/FOAM MAY CAUSE FROTHNG.USE WTR TO COOL
FIRE-(SEE SPEC FF PROC)
Fire Fighting Procedures:EXPOSED CNTNR.IF LEAK/SPLL HAS NOT IGN;USE WTR
SPRAY TO DISPERSE VAPORS & TO PROVIDE.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL IF POSSIBLE. WIPE UP/ABSORB ON
SUITABLE MATERIAL & SHOVEL UP.
Neutralizing Agent:NOT KNOWN .
======================Handling and Storage ======================
Handling and Storage Precautions:MIN FEASIBLE HNDLNG TEMP SHLD BE
MAINTAIND.PERIODS OF EXPOSURE TO HIGH TEMP SHOULD BE MINIMIZED.WTR
CONTAM SHLD BE AVOIDED.
Other Precautions:AVOID SKN CNTCT W/USED MOTOR OILS.MISUSE OF EMPTY
CNTNR CAN BE HAZ.EMPTY CNTNR CAN BE HAZ IF USD TO STORE
TOXIC;FLAM/REAC MATL.CUT/WELD OF EMPTY CNTNR MGHT CAUS
FIRE;EXPLO/TOX FUME FRM RESIDUE.DO NOT PRESSURIZE/EXPO TO OPN
FLM/HEAT(SUP DAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED IF EXPOSURES ARE WITHIN
PERMISSIBLE CONCENTRATIONS(MFR). NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:ADEQUATE TO MEET PERMISSIBLE CONCENTRATIONS.
Other Protective Equipment:NOT KNOWN .
Work Hygienic Practices:EXPOS EMPLO SHLD EXER REAS PERSON
CLEANLINESS;THS INCLU CLEANSNG EXPO SKN AREA SEV TIMES DAILY W/SOAP
& WTR; & (SUP DAT)
Supplemental Safety and Health
RT OF ENTRY:OTHER PRECAU:KEEP CNTNR CLOSD & DRUM BUNGS IN
PLACE.ACCORDING TO MFR:TLV OF PRODUCT IS 5MG/M3 OF AIR FOR MIN OIL
MIST.WRK HYG PRAC:LAUND/DRY CLEAN SOIL WRK CLOTHING AT LEAST
WEEKLY.LD5 0-LC50 MIX:DERML-BLIEVD TO BE >3G/KG(RAB)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:N/DETERMINE
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/DETERMIN
Vapor Density:N/DETERMIN
Spec Gravity:.8899
pH:N/APPL
Evaporation Rate & Reference:NOT DETERMINED
Solubility in Water:NOT DETERMINED
Appearance and Odor:BRIGHT AND CLEAR
Percent Volatiles by Volume:N/DETE
Corrosion Rate:
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NOT KNOWN
Stability Condition to Avoid:NOT KNOWN
Hazardous Decomposition Products:NOT KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDING W/LOCAL, STATE, &
FEDERAL REGULATIONS . PRODUCT HAS BEEN EVALUATED FOR RCRA
CHARACTERISTICS & DOES NOT MEET CRITERIA OF A HAZARDOUS WASTE IF
DISCARDED IN ITS PURCHASED FO RM.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:METHYL ALCOHOL WOOD ALCOHOL, MX0485
CAGE:DO242
CAGE:06DF9
CAGE:DO242
============= Composition/Information on Ingredients =============
Ingred Name:METHANOL; (METHYL ALCOHOL)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 32.04%
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT) 5628 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TOXIC BY INGESTION AND INHALATION. CAN
BE TOXIC BY SKIN ABSORPTION. AFFECTS CENTRAL NERVOUS SYSTEM,
ESPECIALLY OPTIC NERVE. MARKED IMPAIRMENT OF VISION AND ENLARGEMENT
OF THE LIVER HAS BEEN REPORTED W ITH CHRONIC EXPOSURE. CAUSES
DIZZINESS,NAUSEA, MUSCLE WEAKNESS, NARCOSIS, RESPIRATORY FAILURE.
(SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: INGESTION CAN PRODUCE BLINDNESS (100
ML CAN BE FATAL). PROLONGED OR REPEATED SKIN CONTACT MAY CAUSE
IRRITATION. TESTS ON LABORATORY ANIMALS INDICATE MATERIAL MAY
PRODUCE ADVERSE MUTAGENIC AN D REPRODUCTIVE EFFECTS.
Medical Cond Aggravated by Exposure:SKIN CONDITIONS, EYE PROBLEMS, OR
IMPAIRED LIVER OR KIDNEY FUNCTION.
======================= First Aid Measures =======================
First Aid:GET MD FOR ALL CASES OF OVEREXP. SKIN: WASH THORO WITH SOAP
AND WATER. REMOVE CONTAM CLTHG BEFORE REUSE. EYES: IMMED FLUSH
THOROUGHLY WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES.
INHAL: REMOVE TO FRESH AIR; GIVE ARTIFICIAL RESPIRATION IF
BREATHING HAS STOPPED. INGEST: GET IMMED MEDICAL ATTN. IF MEDICAL
ATTN IS NOT IMMED AVAIL, INDUCE VOMIT. DO NOT INDUCE VOMIT IF
PATIENT IS UNCONSCIOUS.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:52.0F,11.1C
Lower Limits:6.7%
Upper Limits:36.5%
Extinguishing Media:DRY CHEMICAL, "ALCOHOL" FOAM, CO2, WATER MIST.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE UPON
HEATING. VAPOR CAN TRAVEL DISTANCES TO IGNITION SOURCES AND FLASH
BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE SPILL; TAKE UP WITH ABSORBENT;
CONTAINERIZE FOR PROPER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. STORE IN A COOL
AREA AWAY FROM IGNIT SOURCES & OXIDIZERS. DO NOT BREATHE VAP/SOLN
MIST.
Other Precautions:DO NOT GET IN EYES, ON SKIN, OR ON CLOTHING.
ELECTRICALLY GROUND ALL EQUIPMENT WHEN HANDLING THIS PRODUCT. DO
NOT TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR SHOULD BE WORN IN
THE ABSENCE OF ADEQUATE VENTILATION.
Ventilation:MATERIAL SHOULD BE HANDLED OR TRANSFERRED IN AN APPROVED
FUME HOOD OR WITH ADEQUATE VENTILATION.
Other Protective Equipment:EYE WASH AND SAFETY EQUIPMENT SHOULD BE
READILY AVAILABLE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F5
Boiling Pt:B.P. Text:148F,64C
Melt/Freeze Pt:M.P/F.P Text:-144F,-98C
Vapor Pres:97
Vapor Density:1.1
Spec Gravity:0.791
Evaporation Rate & Reference:5.91 (BUAC = 1)
Solubility in Water:MISCIBLE
Appearance and Odor:COLORLESS LIQUID, CHARACTERISTIC ALCOHOLIC ODOR.
Percent Volatiles by Volume:99.9+
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, REACTIVE METALS.
Stability Condition to Avoid:HEAT; CONTACT WITH IGNITION SOURCES.
Hazardous Decomposition Products:COX, FORMALDEHYDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:TO BE PERFORMED IN COMPLIANCE WITH ALL CURRENT
LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PERMA-LOK LH050
Preparer's Name:PHILIP A. TOSCANO
CAGE:DO478
CAGE:DO478
CAGE:85091
============= Composition/Information on Ingredients =============
Ingred Name:TETRAETHYLENEGLYCOL DIMETHACRYLATE
CAS:109-17-1
RTECS #:OZ4000000
Fraction by Wt: >1%
Other REC Limits:NONE SPECIFIED
Ingred Name:SACCHARIN (SARA III)
CAS:81-07-2
RTECS #:DE4200000
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:VOC: 0.09 LBS/GAL (10 G/L)
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:17 GM/KG ORAL-MOUSE
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITATING & MAY INJURE EYE
TISSUE IF NOT REMOVED PROMPTLY. SKIN: FREQUENT OR PROLONGED CONTACT
MAY IRRITATE AND CAUSE DERMATITIS. MAY CAUSE SKIN SENSITIZATION, A
PARTIAL OR WHOLE-BODY DERMATITIC RASH EXPERIENCED AFTER EXPOSURE,
HOWEVER, MINIMAL. INHALATION: BASED ON ITS LOW VOLATILITY, PRODUCT
IS NOT CONSIDERED *
Explanation of Carcinogenicity:THERE IS LIMITED EVIDENCE THAT SACCHARIN
IS CARCINOGENIC IN EXPERIMENTAL ANIMALS.
Effects of Overexposure:*TO BE A RESPIRATORY HAZARD UNDER NORMAL
CONDITIONS OF USE. IRRITATING AND/OR TOXIC VAPORS MAY BE RELEASED
AT ELEVATED TEMPERATURES. INGESTION: EFFECTS HAVE NOT BEEN
EVALUATED, BUT ARE ASSUMED TO CAUS E NAUSEA AND VOMITING.
Medical Cond Aggravated by Exposure:TARGET ORGANS: SKIN & EYES.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/LG AMT WATER-15 MIN, LIFT UPPER/LOWER LIDS. GET
MEDICAL AID. SKIN: FLUSH EXPOSED AREAS THOROUGHLY W/SOAP/WATER.
REMOVE CONTAM CLOTHING & LAUNDER BEFORE REUSE. INHALATION: REMOVE
TO FRESH AIR. BREATHING DIFFICULT, GIVE OXYGEN; STOPPED, GIVE CPR.
GET MEDICAL AID. INGEST: DO NOT INDUCE VOMIT IF CONSCIOUS, GIVE
MILK OR WATER. KEEP WARM/QUIET. GET MED AID. NOTHING BY MOUTH TO
UNCONSCIOUS.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:230F,110C
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD BE EQUIPPED WITH SCBA TO
PROTECT AGAINST POTENTIALLY TOXIC AND IRRITATING FUMES. COOL
EXPOSED EQUIPMENT WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:IN LARGER QUANTITIES, COULD UNDERGO
POLYMERIZATION GENERATING SIGNIFICANT HEAT AND PRESSURE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE CLOTHING. STOP LEAK IF YOU CAN
DO IT WITHOUT RISK. FOR SMALL SPILLS, TAKE UP W/SAND OR OTHER INERT
ABSORBENT MAT'L & PLACE IN CONTAINER FOR LATER DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE OUT OF DIRECT SUNLIGHT IN A DRY
AREA. MAXIMUM STORAGE TEMPERATURE IS 100 F.
Other Precautions:AVOID EXCESSIVE HEAT. STORE AT ROOM TEMPERATURE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL HANDLING CONDITIONS.
USE NIOSH APPROVED RESPIRATOR IF VAPOR OR MIST LEVELS ARE
IRRITATING.
Ventilation:GENERAL
Other Protective Equipment:NO SPECIAL CLOTHING REQUIRED FOR LOW VOLUME
ACTIVITY.
Work Hygienic Practices:REMOVE CLOTH & LAUNDER BEFORE REUSE IF
CONTAM.WASH HANDS W/SOAP/WATER OR BEFORE EATING, DRINKING, SMOKING,
USING TOILET.
Supplemental Safety and Health
NOTE: IN BULK QUANTITIES, PRODUCT ABSORBED ON INERT MATERIAL MAY
POLYMERIZE GENERATING SIGNIFICANT HEAT & PRESSURE. VENT DISPOSAL
CONTAINER TO PREVENT BUILDUP OR PRESSURE. CAN CAREFULLY SOLIDIFY
WITH ANAEROBIC SURFACE CONDITIONER & DISPOSEOF AS SOLID WASTE.
================== Physical/Chemical Properties ==================
HCC:T6
Boiling Pt:B.P. Text:POLYMERIZES
Vapor Pres:0.01 @ 77F
Vapor Density:1.01
Spec Gravity:1.070
Viscosity:200,000 CPS
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE PASTE; MILD PLEASANT ODOR
Percent Volatiles by Volume:<1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
METALS AND THEIR SALTS, PERMA-LOK (R) ANAEROBIC SURFACE CONDITIONERS.
Hazardous Decomposition Products:THERMAL DECOMPOSITION COULD PRODUCE
CARBON MONOXIDE, CARBON DIOXIDE AND UNIDENTIFIED ORGANIC COMPOUNDS.
Conditions to Avoid Polymerization:PRODUCTS ARE ANAEROBIC & POLYMERIZE
W/NO AIR. SUNLIGHT, EXCESS HEAT & CONTAM BY METALS WILL ALSO CAUSE
POLYMERIZATION.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE DISPOSAL SHOULD BE IN ACCORDANCE WITH
EXISTING FEDERAL, STATE AND LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:VANADIUM ICP STANDARD, ICP229
CAGE:DO242
CAGE:63612
CAGE:DO242
============= Composition/Information on Ingredients =============
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE HARMFUL IF SWALLOWED.
IRRITATING TO EYES & MUCOUS MEMBRANES. MAY CAUSE EYE INJURY. VAPOR
IRRITATING TO EYES & RESPIRATORY PASSAGES. MAY BE IRRITATING ON
CONTACT W/SKIN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:RESPIRATORY CONDITIONS.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ASSISTANCE FOR ALL CASES OF OVEREXPOSURE.
SKIN:WASH THOROUGHLY W/SOAP & WATER. EYE:IMMEDIATELY FLUSH
THOROUGHLY W/WATER FOR AT LEAST 15 MINUTES. INHAL:REMOVE TO FRESH
AIR; GIVE ARTIFICIAL RESPIRATION IF BREATHING HAS STOPPED.
INGEST:GET IMMEDIATE MEDICAL ATTENTION; IF CONSCIOUS, GIVE WATER
FREELY.
===================== Fire Fighting Measures =====================
Flash Point:NONCOMBUSTIBLE
Extinguishing Media:USE ANY SUITABLE FOR ADJACENT MATERIAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCES TOXIC
FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA OF ALL UNNEC PERS. WEAR SUITABLE
PROT EQUIP LISTED UNDER EXPOS/PERSONAL PROT. ELIM ANY IGNIT SOURCES
UNTIL AREA IS DETERMINED TO BE FREE FROM EXPLO/FIRE HAZS. CONTAIN
RELS & ELIM ITS SOU RCE, IF THIS CAN BE DONE W/OUT RISK. TAKE
(SUPDAT)
Neutralizing Agent:FOLLOWING EM SCIENCE SPILL-X NEUTRALIZER & ABSORB IS
REC FOR THIS PROD: (ING 7)
======================Handling and Storage ======================
Handling and Storage Precautions:CORROSIVE LIQUID. KEEP CONTAINER
CLOSED. STORE AT CONTROLLED ROOM TEMPERATURE. DO NOT BREATHE VAPOR.
DO NOT GET IN EYES, ON SKIN, OR ON CLOTHING.
Other Precautions:DO NOT TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:MATERIAL SHOULD BE HANDLED OR TRANSFERRED IN AN APPROVED
FUME HOOD OR W/ADEQUATE VENTILATION.
Other Protective Equipment:EMERG EYE WASH & DELUGE SHOWER WHICH MEETS
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
SPILL PROC:UP & CONTAINERIZE FOR PROPER DISP AS DESCRIBED UNDER DISP.
COMPLY W/FED, STATE & LOC REGS ON REPORTING RELS. REFER TO
REGULATORY INFO FOR REPORTABLE QTY & OTHER REGULATORY DATA. EM
SCIENCE RECS SPILL-X NEUTRALIZERS & ABSORB AGENTS FOR VARIOUS TYPE
OF SPILLS. ADDNL INFO ON SPILL-X PRODS CAN BE PROVIDED(ING 6)
================== Physical/Chemical Properties ==================
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE INDICATED.
Stability Condition to Avoid:EXTREME HEAT.
Hazardous Decomposition Products:NO*X.
==================== Disposal Considerations ====================
Waste Disposal Methods:EPA WASTE NUMBERS:D002. SPECIFIED TECHNOLOGY -
NEUT TO PH 6-9. CONT YOUR LOC PERMITTED WASTE DISP SITE (TSD) FOR
PERMISSIBLE TREATMENT SITES. ALWAYS CONT PERMITTED WASTE DISPOSER
(TSD) TO ASSURE COMPL IANCE W/ALL CURRENT LOC, STATE & FED REGS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:520 ADHESIVE
CAGE:03938
CAGE:03938
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE (SARA 313) (CERCLA)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 25%
OSHA PEL:1000 PPM
ACGIH TLV:750 PPM/1000 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TOLUENE (SARA 313) (CERCLA)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 16%
OSHA PEL:200 PPM; Z-2
ACGIH TLV:S, 50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HEXANE (CERCLA)
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: 34%
OSHA PEL:500 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:1,3-BUTADIENE, 2-CHLORO-, POLYMERS; (SYNTHETIC RUBBER)
CAS:9010-98-4
RTECS #:EI9460000
Fraction by Wt: 13%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PHENOLIC RESIN
Fraction by Wt: 9%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:RUBBER CURING INGREDIENTS
Fraction by Wt: 3%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TOLUENE APPEARS ON THE NAVY LISTING OF
OCCUP CHEM REPROD HAZARDS. SEEK CONSULTATION FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZARD LIST INFO & SAFE HNDLG &
EXPOS INFO . ACUTE:EXCESSIVE SKIN CONT MAY CAUSE DRYING & CRACKING
OF SKIN, & RSLT IN DERM. CONT W/EYES WILL CAUSE IRRIT. (EFTS OF
OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:INHAL:IRRIT OF RESP TRACT, COUGHING,
HEADACHE, DIZZINESS, DROWSINESS, NAUSEA; UNCOORDINATED MOVEMENTS.
Medical Cond Aggravated by Exposure:ANY CONDITION GENERALLY AGGRAVATED
BY SOLVENTS; PREEXISTING UPPER RESPIRATORY & LUNG DISEASE SUCH AS,
BUT NOT LIMITED TO BRONCHITIS, EMPHYSEMA, AND ASTHMA.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . SKIN & EYES:FLUSH WITH PLENTY OF
WATER FOR @ LEAST 15 MINUTES. ADDITIONALLY WITH SKIN CONT, WASH
W/SOAP & WATER. REFER TO PHYS IF IRRIT OR SYMPTOMS PERSIST.
INHAL:RE MOVE TO FRESH AIR IF EXPOSED TO EXCESS CONC OF VAPOR. SEEK
MED ATTN IF SYMPTOMS PERSIST.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:<20F,<-7C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, HALON.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CLOSED CNTNRS IN FIRE MAY RUPTURE DUE TO
PRESS BUILD-UP; USE WATER TO COOL CNTNRS TO PREVENT THIS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT. VENTILATE AREA OF
SPILL/LEAK; IF USING MECH VENT, MAKE SURE THAT IT IS EXPLO-PROOF OR
DOES NOT PRESENT IGNIT SOURCE. FOR EXPOS ABOVE TLV, WEAR APPRVD
RESP EQUIP. CONTAIN S PILL, PREVENTING IT FROM ENTERING
SEWER(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN AREA SUITABLE FOR FLAM
MIXTURES. REC STOR TEMP IS BELOW 90 DEGREES F. VAPS ARE FLAM & ARE
HVR/AIR.
Other Precautions:PROHIBIT SMOKING & ELIM ALL OTHER SOURCES OF IGNIT,
SUCH AS REGULAR ELEC TOOLS & APPLIANCES, MAKING SURE THAT PILOTS ON
GAS-FIRED WATER HEATERS ARE EXTINGUISHED. WARNING:PROD CONTAINS
TOLUENE, CHEM KN OWN TO ST OF CA TO CAUSE (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WITH ADEQ VENT, NIOSH/MSHA RESP EQUIP SHOULD NOT
BE NEEDED. IF ADEQ VENT IS NOT AFFORDED, WEAR NIOSH/MSHA RESP EQUIP
APPRVD FOR ORGANIC VAPORS.
Ventilation:USE NATURAL CROSS-VENT, LOCAL (MECHANICAL) PICK-UP, AND/OR
GEN AREA (MECH)VENT TO PVNT AN ACCUM OF SOLV VAPS, (SUPDAT)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPILL RELEASE:LINES/WATERWAYS. USE ABSORB TO ASSIST W/PICK-UP OF MATL.
SCRAPE UP ADHESIVE & PLACE IN CNTNR. OTHER PRECAUT:BIRTH
DEFECTS/OTHER REPROD HARM. VENT:FROM LOWER LEV OF WORK SPACES. VENT
SHOU LD BE SUFFICIENT TO KEEP SOLV VAP CONC BELOW TLV.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>152F,>67C
Spec Gravity:0.83 (H*2O=1)
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:NEGLIGIBLE
Appearance and Odor:STRAW COLORED LIQUID WITH CHARACTERISTIC SOLVENT
ODOR
Percent Volatiles by Volume:75(WT)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, AND
OTHER TOX VAPS & GASES THAT ARE COMMON TO THERMAL DEGRADATION OF
ORG CMPDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCIN/OTHER METHOD APPROVED FOR IGNITIBLE WASTES
I/A/W FEDERAL, STATE, AND LOCAL REGULATIONS. THIS PROD CONTAINS
CHEM SUBJECT TO REPORTING REQUIREMENTS OF 313 OF TITLE III OF
SUPERFUND AMENDMENT & REA UTHORIZATION ACT OF 1986 & 40 CFR PART
372.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:16-0357 CUTTING OIL
CAGE:59581
CAGE:59581
============= Composition/Information on Ingredients =============
Ingred Name:CUTTING OIL (MIST)
Fraction by Wt: 95%
OSHA PEL:5 MG/CUM
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 3%
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9192
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 2%
Other REC Limits:1000 PPM
OSHA PEL:1800 MG/CUM
ACGIH TLV:1000 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: DEFATTING,
IRRITATION & DERMATITIS. INHALATION: RESPIRATORY SYSTEM IRRITATION,
HEADACHE, DIZZINESS, NAUSEA, POSSIBLE UNCONSCIOUSNESS &
ASPHYXIATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION. SKIN: DEFATTING, IRRITATION &
DERMATITIS. INHALATION: RESPIRATORY SYSTEM IRRITATION, HEADACHE,
DIZZINESS, NAUSEA, POSSIBLE UNCONSCIOUSNESS & ASPHYXIATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MIN. SKIN: WASH W/SOAP &
WATER. INHALATION: REMOVE TO FRESH AIR. IF BREATHING STOPS, BEGIN
ARTIFICIAL RESPIRATION. INGESTION: OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:10F
Extinguishing Media:CO2, DRY CHEMICAL OR FOAM
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS
USED, FOG NOZZLES ARE PREFERABLE. WEAR SELF-CONTAINED BREATHING
APPARATUS. USE WATER TO COOL CONTAINERS.
Unusual Fire/Explosion Hazard:EXPOSURE TO HEAT OR SUNLIGHT MAY CAUSE
BURSTING OF AEROSOL CAN.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE
AREA. WIPE UP W/INERT MATERIALS & PLACE IN APPROPRIATE CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE >120F. USE ONLY AS
DIRECTED. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING VAPORS &
INHALING CONTENTS CAN BE HARMFUL OR FATAL.
Other Precautions:AVOID BREATHING SOLVENT VAPORS & SPRAY MISTS. AVOID
CONTACT W/SKIN & EYES. USE W/ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE SELF-CONTAINED BREATHING APPARATUS IF >TLV.
Ventilation:ADEQUATE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Pres:40 PSIG
Vapor Density:>AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Percent Volatiles by Volume:85%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING & REDUCING AGENTS
Stability Condition to Avoid:TEMPERATURES >120F, HEAT, SPARKS, PILOT
LIGHTS, OPEN FLAME OR OTHER SOURCE OF IGNITION, SUNLIGHT
Hazardous Decomposition Products:HAZARDOUS FUMES, CO2, CO, HYDROGEN
CHLORIDE, OXIDES OF NITROGEN & SULFUR, ALDEHYDES & KETONES
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T INCINERATE. DISPOSE OF IN ACCORDANCE
W/FEDERAL, STATE & LOCAL REGULATIONS. DON'T PLACE AEROSOL CANS IN
HOME COMPACTOR. DON'T PUNCTURE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:VERR-CANTH
CAGE:9Z340
CAGE:9Z340
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Other REC Limits:NONE SPECIFIED
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CANTHARIDIN (SARA III)
CAS:56-25-7
RTECS #:RN8575000
Other REC Limits:NONE SPECIFIED
Ingred Name:2-ETHOXYETHANOL (EGEE) (SARA III) (CELLOSOLVE)
CAS:110-80-5
RTECS #:KK8050000
Other REC Limits:NONE SPECIFIED
OSHA PEL:S,200 PPM
ACGIH TLV:S, 5 PPM; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:COLLODION
RTECS #:GH2110000
Other REC Limits:NONE SPECIFIED
Ingred Name:COATED SAND (ETHYL CELLULOSE)
CAS:9004-57-3
RTECS #:FJ5950500
Other REC Limits:NONE SPECIFIED
Ingred Name:ETHYL ETHER (SARA III)
CAS:60-29-7
RTECS #:KI5775000
Other REC Limits:NONE SPECIFIED
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400PPM/500STEL; 9192
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:GLYCOLS, POLYETHYLENE, MONO(P-(1,1,3,3-TETRAMETHYL
BUTYL)PHENYL) ETHER (TRITON X)
CAS:9002-93-1
RTECS #:MD0907700
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:ACUTE: MAY BE IRRITATING TO EYES, SKIN
AND MUCOUS MEMBRANES ON CONTACT. MAY CAUSE GENERAL ANESTHESIA IF
INHALED; SEVERE EXPOSURE MAY LEAD TO RESPIRATORY FAILURE AND DEATH.
MAY CAUSE SEVERE STOMACH DIS TRESS IF INGESTED. CHRONIC: KIDNEY AND
LUNG DAMAGE.
Explanation of Carcinogenicity:NONE SPECIFIED BY MANUFACTURER.
Effects of Overexposure:INHALATION: COUGHING, WHEEZING, SHORTNESS OF
BREATH, HEADACHE, DIZZINESS, NAUSEA, UNCONSCIOUSNESS. EYES:
REDNESS, ITCHING, TEARING. SKIN: DRYING, REDNESS, RASH. INGESTION:
BURNING SENSATION IN STOMACH , SEVERE STOMACH PAIN, INTERNAL BURNS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER. MAY
AGGRAVATE PREEXISTING SKIN OR RESPIRATORY DISORDERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESUSCITATE IF NEEDED. EYES:
FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS OPEN. SEE
DOCTOR. SKIN: WASH WITH SOAP AND WATER. INGESTION: GIVE LARGE
AMOUNTS OF W ATER IF CONSCIOUS. INDUCE VOMITING. GETIMMEDIATE
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:-49F,-45C
Lower Limits:1.85%
Upper Limits:36%
Extinguishing Media:DRY CHEMICAL, FOAM, OR CARBON DIOXIDE
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE GEAR. WATER INEFFECTIVE TO PUT FIRE OUT; USE TO
CONTROL FIRE. COOL FIRE EXPOSED CONTAINERS W/ WATER.
Unusual Fire/Explosion Hazard:A HIGHLY FLAMMABLE LIQUID WHEN HEATED AND
EXPOSED TO FIRE OR SPARKS, VAPOR IS HEAVIER THAN AIR AND MAY TRAVEL
A CONSIDERABLE DISTANCE TO IGNITE AND FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE
SPILL AREA. REMOVE NONESSENTIAL PEOPLE. WEAR PROPER PROTECTIVE
EQUIPMENT. ABSORB WITH INERT MATERIAL. PLACE IN CONTAINER FOR
DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT AGAINST PHYSICAL DAMAGE. AVOID
SUNLIGHT. ISOLATE FROM OTHER COMBUSTIBLES AND OXIDIZING MATERIALS.
Other Precautions:DO NOT BREATH VAPORS. IF MATERIAL IS OLD OR LONG
STANDING UNSTABLE PEROXIDES MAY HAVE FORMED; HANDLE WITH CAUTION!
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. SELF CONTAINED BREATHING
APPARATUS IF REGULATORY LIMITS EXCEEDED.
Ventilation:USE LOCAL EXHAUST (EXPLOSION-PROOF).
Other Protective Equipment:LAB COAT OR COVERALLS
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
PHYSICAL DATA IS FOR ETHER- NOT THE MIXTURE AS A WHOLE.
================== Physical/Chemical Properties ==================
HCC:F1
Boiling Pt:B.P. Text:94.0F,34.4C
Vapor Pres:442
Vapor Density:2.56
Spec Gravity:0.71
Evaporation Rate & Reference:1 (N-BUTYL ACETATE=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:YELLOW-GOLD COLORED LIQUID WITH ODOR OF ACETONE AND
ETHER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HYDROFLUORIC AND NITRIC ACID, STRONG OXIDIZING AGENTS, IODIDES,
ALBUMIN, CHLORINE, BROMOAZIDE, LIQUID AIR,ACETYL PEROXID
Stability Condition to Avoid:LONG STANDING OR AGING- UNSTABLE PEROXIDES
FORM.
Hazardous Decomposition Products:OXIDES OF CARBON, PHENOL, ALIPHATIC
ALDEHYDES, AND CARBOXCYLIC ACIDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:WD-40 AEROSOL
Preparer's Name:R.MILES
CAGE:09137
CAGE:09137
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 50%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9596
Ingred Name:LPG (LIQUEFIED PETROLEUM GAS)
CAS:68476-85-7
RTECS #:SE7545000
Fraction by Wt: 25%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9596
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATE, SOLVENT DEWAXED (MILD),
HEAVY PARAFFINIC
CAS:64742-65-0
RTECS #:PY8038500
Fraction by Wt: >15%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: <10%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV IS 100PPM(ALIPHATIC PET DISTILLATES)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:MAY CAUSE IRRITATION.SKIN:MAY
CAUSE IRRITATION AND DRYNESS.INGEST:MAY CAUSE GI TRACT
IRRITATION.MAY CAUSE LUNG DAMAGE IF VOMITED AFTER
INGESTING.INHAL:MAY CAUSE RESPIRATORY IRRITATION AND CNS EFF ECTS.
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of
Overexposure:INHAL:ANESTHESIA,HEADACHE,DIZZINESS,NAUSEA.EYES:TEARIN
G,REDNESS.INGEST:NAUSEA,VOMITING,DIARRHEA.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH SOAP AND
WATER.EYES:FLUSH WITH WATER FOR 15 MINUTES.INHAL:REMOVE TO FRESH
AIR.GIVE OXYGEN OR ARTIFICIAL RESPIRATION IF NEEDED.INGEST:DO NOT
INDUCE VOMITING. GET PROMPT QUALIFIED MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:EXTREMELY FLAMBL
Lower Limits:1.8
Upper Limits:9.5
Extinguishing Media:DRY CHEMICAL,CARBON DIOXIDE,FOAM.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.COOL FIRE EXPOSED CONTAINERS WITH WATER
FOG.
Unusual Fire/Explosion Hazard:**EXTREMELY FLAMMABLE - U.F.C. LEVEL 3
AEROSOL**
================== Accidental Release Measures ==================
Spill Release Procedures:SPILL IS UNLIKELY FROM AEROSOL CANS.LEAKING
CANS SHOULD BE PLACED IN A PLASTIC BAG OR PAIL UNTIL PRESSURE HAS
DISSIPATED.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT TEMPERATURES BELOW
120F.FOLLOW LABEL DIRECTIONS.
Other Precautions:FOLLOW LABEL DIRECTIONS.AVOID BREATHING VAPORS.AVOID
SKIN AND EYE CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE ENVIRONMENTAL CONTROLS ARE LACKING OR IN
ENCLOSED SPACES USE A NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC
VAPORS.
Ventilation:USE GENERAL DILUTION VENTILATION.
Other Protective Equipment:NONE
Work Hygienic Practices:USE REASONABLE CARE IN HANDLING THIS
PRODUCT.WASH HANDS AFTER USE AND BEFORE EATING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:V3
Vapor Pres:55PSI@70F
Vapor Density:>1
Spec Gravity:0.71
Solubility in Water:INSOLUBLE
Appearance and Odor:AEROSOL.LIQUID IS LIGHT AMBER WITH CHARACTERITIC
ODOR.
Percent Volatiles by Volume:80
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH HEAT,SOURCES OF IGNITION.
Hazardous Decomposition Products:CARBON DIOXIDE,CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.EMPTY AEROSOL CANS SHOULD NOT BE PUNCTURED OR
INCINERATED;LIQUID SHOULD BE INCINERATED OR BURIED IN LAND
FILL.RCRA CODE D001(IGNITABLE ).
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:WOOD FINISH PURITAN PINE 218
CAGE:HO239
CAGE:HO239
CAGE:80882
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 86.0%
Other REC Limits:N/K
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9293
Ingred Name:VEHICLE
Fraction by Wt: 10.0%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ADDITIVES
Fraction by Wt: 1.0%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PIGMENTS
Fraction by Wt: 3.0%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CAN CAUSE DEFATTING AND DRYING OF THE
SKIN WHICH MAY RESULT IN DERMATITIS.INHALATION CAN CAUSE
ASPHYXIATION.ASPIRATION OF MATERIAL INTO LUNGS DUE TO VOMITING CAN
CAUSE CHEMICAL PNEUMONITIS WHICH CAN B E FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:SEVERE IRRITATION,REDNESS,TEARING,BLURRED
VISION.SKIN:DEFATTING AND DRYING MAY RESULT IN IRRITATION AND
DERMATITIS.INGESTION:GASTROINTESTINAL
IRRITATION,NAUSEA,VOMITING,DIARRHEA.INHALATION:NASAL & RESPIRATORY
IRRITATION,DIZZINESS,FATIGUE,NAUSEA,HEADACHE,NERVOUS
IRRITABILITY,UNCONSCIOUSNESS,ASPHYXIATION.
Medical Cond Aggravated by Exposure:N/K
======================= First Aid Measures =======================
First Aid:EYES:REMOVE CONTACT LENSES IF PRESENT;FLUSH W/ PLENTY OF
WATER FOR AT LEAST 15 MINUTES & GET MEDICAL ATTENTION.SKIN:WASH
THOROUGHLY W/ SOAP & PLENTY OF WATER.IF IRRITATION PERSISTS GET
MEDICAL ATTENTI ON.INGEST:DO NOT INDUCE VOMITING.CALL MD
IMMEDIATELY.KEEP PATIENT WARM & QUIET.ASPIR INTO LUNGS DUE TO VOMIT
CAN CAUSE FATAL CHEM PNEUM.INHAL:REMOVE TO FRESH AIR.MAINTAIN
RESPIRATION AS NEC & CALL MD.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:105F,41C
Lower Limits:6.0
Upper Limits:0.9
Extinguishing Media:CARBON DIOXIDE,DRY CHEMICAL,ALCOHOL FOAM AND WATER
FOG.WATER NOT NORMALLY AN EFFECTIVE EXTINGUISHING AGENT.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROT EQUIP
W/ FULL FACEPIECE IN PRESS DEMAND MODE.TOXIC BY-PRODUCTS GIVEN OFF
(CO);AVOID BREATHING SMOKE AND GASES.
Unusual Fire/Explosion Hazard:NONE.HAZARDOUS DECOMPOSITION
PRODUCTS:INCOMPLETE COMBUSTION PRODUCES CARBON MONOXIDE,CARBON
DIOXIDE,AND UNIDENTIFIED ORGANIC COMPOUNDS.AUTOIGNIT:450F,232C.
================== Accidental Release Measures ==================
Spill Release Procedures:PROVIDE ADEQUATE VENTILATION.REMOVE IGNITION
SOURCES FROM SPILL AREA.UTILIZE SAND,RAGS,PAPER,VERMICULITE,FLOOR
ABSORBENT MATERIAL & PLACE IN LEAK-PROOF DRUMS FOR DISPOSAL.USE
PROTECTIVE EQUIPMENT.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF SURFACE WATERS & ANY WATER
COURSES OR SEWERS ENTERING/LEADING TO SURFACE WATERS.DO NOT
USE/STORE NEAR HEAT,SPARKS,OPEN FLAMES,(SEE SUPP)
Other Precautions:KEEP OUT OF REACH OF CHILDREN.AVOID SPONT COMBUST OF
CONTAM RAGS,OTHER IGNITABLE MATL BY IMMED WATER IMMERSION.EMPTY
CONTR RETAINS RESIDUES;DO NOT CUT,PUNCTURE,WELD ON/NEAR CONTR.AVOID
INHAL,USE W/ AD EQ VENT.IF EMPLOYEE EXPERIENCES (SUP DA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Other Protective Equipment:HAVE EYE BATH & SAFETY SHOWER NEARBY DURING
USE.
Work Hygienic Practices:WASH W/ SOAP,WATER BEFORE
EATING,DRINKING,SMKNG,USING TOILET FACILITIES.REMOVE CONTAM CLTHG
IMMED,LAUNDER BEFORE REUSE.
Supplemental Safety and Health
HNDLG/STOR PREC:OTHER IGNIT SOURCES.CLOSE CONTR AFTER EACH USE.STORE
ONLY IN ORIGINAL CONTR.OTHER PREC:EYE
WATERING,HEADACHES,DIZZINESS;INCR FRESH AIR,LEAVE AREA.DO NOT TAKE
INTERNALLY.ROUTES OF ENTRY :INGESTION .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:313F,156C
Decomp Temp:Decomp Text:N/K
Vapor Pres:2.00 MMHG
Vapor Density:4.8,AIR=1
Spec Gravity:0.794 (WATER=1)
Evaporation Rate & Reference:0.09 (BUTYL ACETATE=1)
Solubility in Water:NIL
Appearance and Odor:AMBER LIQUID;MILD HYDROCARBON ODOR.
Percent Volatiles by Volume:88.2
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:INCOMPLETE COMBUSTION PRODUCES CARBON
MONOXIDE,CARBON DIOXIDE,AND UNIDENTIFIED ORGANIC COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .INCINERATION IS PREFERRED.RCRA
HAZARDOUS WASTE CLASSIFICATION IGNITABLE,NUMBER D001.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MOPAR 60 BATTERY 815 AMPS
CAGE:18113
CAGE:18113
CAGE:86403
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 10-30%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PROPENE POLYMERS; (POLYPROPYLENE)
CAS:9003-07-4
RTECS #:UD1842000
Fraction by Wt: 5-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:LEAD (SARA 313) (CERCLA)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 30-60%
OSHA PEL:SEE 1910.1025
ACGIH TLV:0.15MG/M3 DUST
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:LEAD DIOXIDE
CAS:1309-60-0
RTECS #:OG0700000
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:LEAD(II)SULFATE(1:1) (SARA 313) (CERCLA)
CAS:7446-14-2
RTECS #:OG4375000
Fraction by Wt: 1-5%
OSHA PEL:SEE 1910.1025
ACGIH TLV:0.15 MG(PB)/M3
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:SULFURIC ACID (SARA 302/313) (CERCLA)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 5-10%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3/3 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SUPP DATA: HANDLE CAREFULLY WHILE TRANSFERRING/HNDLG TO
PVNT SPLASHING ON CLTHS/UNPROTECTED SKIN.
RTECS #:9999999ZZ
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP: LATEST HAZARD LIST INFORMATION AND SAFE
HANDLING AND EXPOSURE INFORMATION. LEAD POISONING(ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: IS CHARACTERIZED BY A METALLIC TASTE IN MOUTH, LOSS
OF APPETITE, INDIGESTION, NAUSEA, VOMIT, CONSTIPATION(ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: ABDOMINAL CRAMPS, DISTURBANCE OF REST AND SLEEP AND
WEAKNESS.
RTECS #:9999999ZZ
Ingred Name:STOR/HNDLG: WEAR NIOSH/MSHA APPROVED RESPIRATORY PROTECTION
WHEN HANDLING LIQUID DURING SPILL OR NORMAL POURING (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: DUE TO GAS OR VAPOR EXPOSURE.
RTECS #:9999999ZZ
Ingred Name:EYE PROT: & FULL LENGTH FACESHIELD.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INGEST: MAY PRDCE NAUS,
VOMIT,DIARR & ABDOM CRAMPS, BURNS IN MOUTH, THROAT & STOM. EYE:
CORROSIVE. MIST WILL PRDCE DMG TO EYE TISS & SEV BURN. SKIN: DIRECT
CONT MAY PRDCE SEV BURN. MAY BE CORR, CAUSING ULCERATION &
BLISTERS. INHAL: MAY PRDCE BRONCHIAL IRRIT & CHEM PNEUM (AN INFLAMM
OF LUNGS. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SULFURIC ACID: IARC MONO ON EVAL OF
CARCIN RISK OF CHEMICALS TO MAN, VOL 54, PG 41, 1992: GROUP 1.
ANIMAL: PULM IRRIT.
Effects of Overexposure:HLTH HAZ:SIMILAR TO PNEUM, WHICH IS CAUSED BY
GETTING LIQUID FORM OF CHEM INTO LUNGS). CHRONIC: EXPOS MAY PRDCE
DMG TO NERVOUS SYS &/BRAIN DMG, KIDNEY DMG, ANEMIA AND MAY CAUSE
REPRO EFTS. NOTE: LEAD APPEARS ON THE NAVY LISTING OF OCCUP CHEM
REPRO HAZS. SEEK CONSULT FROM APPROP HLTH PROFESSIONALS CONCERNING
(ING 9)
Medical Cond Aggravated by Exposure:PRE-EXISTING KIDNEY DISORDERS,
PRE-EXISTING LIVER DISORDERS, SKIN DISORDERS, NERVOUS SYSTEM
DISORDERS.
======================= First Aid Measures =======================
First Aid:INGEST: DO NOT INDUCE VOMITING, CALL MD IMMED, DRINK LGE QTYS
OF WATER. EYE: RINSE IMMED W/LGE AMTS OF WATER, OCCAS LIFTING BOTH
UPPER & LOWER LIDS. CONTINUE FOR AT LEAST 15 MINS. CONTACT MD.
SKIN: WA SH W/SOAP & WATER. REMOVE CONTAMD CLTHG. CONT MD. INHAL:
REMOVE TO FRESH AIR AT ONCE. ARTF RESP IF BRTHG HAS STOPPED.
CARDIAC RESUSCITATION IF INDICATED. CONTACT MD.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL, FOAM EXTINGUISHER, CARBON DIOXIDE,
WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT. FIGHT FIRE FROM EXPLOSION RESISTANT AREA.
Unusual Fire/Explosion Hazard:CAPABLE OF IGNITING COMBUST MATLS.
MIST/AEROSOL ACCUMS MAY FLASH IF IGNITED. ORGANIC SOLVENTS WILL
DISSOLVE POLYSTYRENE & COULD FORM AN EXPLOS SOLN.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIM ALL IGNIT SOURCES(FLAMES, HOT SURFS &
ELEC, STATIC/FRICTIONAL SPARKS). CNTN W/DIKE. NEUT W/SODA ASH/NEUT
TO PH 7 OR 8 W/LIME. ABSORB ON INERT MATL & REMOVE W/NON-SPARKING
TOOLS. DISCARD INTO SEAL ED CNTNRS FOR DISP. NEUT WASTE MAY
HAVETO(SUPDAT)
Neutralizing Agent:SODA ASH; LIME.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM HEAT, SPARK/OPEN FLAMES.
STORE SEPARATE FROM INCOMPATIBLE MATLS. STORE IN AREA WHICH WILL
NOT PERMIT ACCESS TO SANITARY/SURF DRAINS.(ING 13)
Other Precautions:STORE ISOLATED FROM COMBUST MATLS. REACTS
W/OXIDIZERS. REACTS W/REDUCING AGENTS. ADD ACID TO WATER, DO NOT
ADD WATER TO ACID, HEAT IS GENERATED UPON DILUTION. BOND & GROUND
ALL CANS, DRUMS, MIXERS, ET C., TO PVNT STATIC SPARKS. (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL PROT NEEDED UNDER NORMAL CNDTNS.
NIOSH/MSHA APPROVED HEPA FILTER/DUST AND MIST RESPIRATOR WITH
PREFILTER. IF NEEDED, RESTRICTED VENT AREAS, NIOSH/MSHA APPROVED
ACID GAS RESPIRATOR.
Ventilation:GOOD GENL VENT IS ADVISED TO MAINTAIN TLV.
Other Protective Equipment:ANSI APPRVD EMERGENCY EYEWASH & DELUGE
SLEEVES.
Work Hygienic Practices:WASH THORO AFTER HNDLG. REMOVE CONTAMD CLTHG.
LAUNDER BEFORE REUSE. DISCARD CONTAMD LEATHER CLTHG.
Supplemental Safety and Health
MATL TO AVOID: OXIDIZING AGENTS. SPILL PROC: BE DISP OF BY AN APPRVD
CONTRACTOR. WEAR PROT CLTHG. WEAR NIOSH/MSHA APPRVD RESP PROT.
OTHER PREC: AVOID BRTHG MIST, SKIN & EYE CONT, INGEST. LEATHER
CLTHG & SHOES WILL BE DMGD BY PRODUCT. ASPIROF MATL INTO LUNGS DUE
TO VOMIT CAN CAUSE CHEM PNEUM WHICH CAN BE FATAL.(ING 7)
================== Physical/Chemical Properties ==================
pH:<2.0
Appearance and Odor:TRANSPARENT OPAQUE FORMED PLASTIC, ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REDUCING AGENTS, ORG MATLS, HYDROGEN PEROXIDE, CHLORATE, SULFIDES,
NITRATES, ALKALINE EARTH METALS & STRONG (SUPDAT)
Stability Condition to Avoid:SPARKS OR OPEN FLAME, HIGH TEMPS,
ELECTRICAL ARC.
Hazardous Decomposition Products:OXIDES OF LEAD & SULFUR ALONG
W/HYDROGEN GAS MAY BE RELEASED. OVERCHARGE RELEASES SULFURIC ACID
MIST & HYDROGEN GAS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT FLUSH INTO SEWER SYSTEM. NEUTRALIZE,
ABSORB ON AN INERT MATERIAL & REMOVE W/NON-SPARKING TOOLS, DISCARD
INTO SEALED CNTNRS FOR DISP. DISP OF IN A MANNER CONSISTENT
W/STATE, PROVINCIAL, LOCAL, A ND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:5500 SERIES FLAT POSTER INK,5544
CAGE:76708
CAGE:06608
CAGE:76708
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC/PETROLEUM
DISTILLATE,ALIPHATIC HYDROCARBON
CAS:64742-88-7
Fraction by Wt: 25 - 50%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:PIGMENTS/PIGMENTS MIXTURE
Fraction by Wt: 15 - 40%
Other REC Limits:NONE RECOMMENDED
Ingred Name:RESIN/RESIN MIXTURES
Fraction by Wt: 10 - 20%
Other REC Limits:NONE RECOMMENDED
Ingred Name:LEAD (SARA 313) (CERCLA)/LEAD COMPOUNDS
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 1 - 22%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE 1910.1025
ACGIH TLV:0.15MG/M3 DUST; 9495
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:PETROLEUM HYDROCARBON,
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 0 - 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:NAPHTHA, LIGHT AROMATIC (SOLVENT NAPHTHA)/PETROLEUM
DISTILLATE, AROMATIC HYDROCARBON
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 0 - 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 AS OIL MIST
ACGIH TLV:5 MG/M3 AS OIL MIST
Ingred Name:1,2,4-TRIMETHYLBENZENE (SARA 313)
CAS:95-63-6
RTECS #:DC3325000
Fraction by Wt: 0 - 2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:25 PPM
ACGIH TLV:25 PPM; 9495
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE
CAS:14464-46-1
RTECS #:VV7325000
Fraction by Wt: <7%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.05 MG/M3 RDUST9495
Ingred Name:CHROMIUM (SARA 313) (CERCLA)/CHROMIUM COMPOUNDS
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: <4%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3; 9495
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:XYLENES (O-,M-,P- ISOMERS) (SARA 313) (CERCLA)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: <2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOLITILE ORGANIC CONTENT AS LISTED ON MSDS: 505 G/L.
RTECS #:9999999VC
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV FOR XYLENE IS 100 PPM.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, CNS, BLOOD,
LIVER, KIDNEY, RESPIRATORY & GI TRACTS. ACUTE- MAY CAUSE EYE, SKIN,
RESPIRATORY & GI TRACTS IRRITATION. HARMFUL IF
INHALED/INGESTED/ABSORBED THROUGH SKIN. CNS DEPR ESSION. MAY CAUSE
DRY SKIN. CHRONIC- MAY CAUSE LIVER, KIDNEY, BRAIN, LUNG DAMAGE,
DERMATITIS, SILICOSIS.
Explanation of Carcinogenicity:CONTAINS CRYSTALLINE SILICA AND LEAD
COMPOUND.
Effects of Overexposure:IRRITATION, TEARING, REDNESS AND STINGING OF
EYES, REDNESS, BURNING, DRYING AND CRACKING OF SKIN, NAUSEA,
VOMITING, DIARRHEA, DIZZINESS, HEADACHE, DROWSINESS, WEAKNESS,
FATIGUE, UNCONSCIOUSNESS
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, LIVER,
KIDNEY, CNS OR RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM
EXPOSURE.
======================= First Aid Measures =======================
First Aid:CALL PHYSICIAN IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15
MINUTES. HOLD EYELIDS OPEN. SKIN:WASH WITH SOAP & WATER. ORAL:DO
NOT INDUCEVOMITING. IF PERSON IS DROWSY/UNCONSCIOUS, PLACE ON
LEFT SIDE WITH HEAD DOWN. GET MEDICAL ATTENTION IMMEDIATELY. IF
POSSIBLE, DO NOT LEAVE INDIVIDUAL UNATTENDED.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:100F,38C
Lower Limits:1.0%
Extinguishing Media:USE DRY CHEMICAL, CARBON DIOXIDE, WATER SPRAY.
WATER MAY BE INEFFECTIVE. COOL FIRE EXPOSED CONTAINERS WITH WATER.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR MAY TRAVEL TO
IGNITION SOURCE & "FLASH BACK". VAPOR MAY EXPLODE IF IGNITED IN AN
ENCLOSED AREA. CONTAINERS MAY EXPLODE DUE TO FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. CONTAIN SPILL. PICK UP SPILL WITH
NON-FLAMMABLE ABSORBENT SUCH AS SAND, EARTH/USE PUMP (EXPLOSION
PROOF). GROUND ALL HANDLING EQUIPMENTS. PREVENT LIQUID FROM
ENTERING SEWERS.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, VENTILATED AREA, AWAY
FROM SOURCES OF IGNITION & INCOMPATIBLES. BOND & GROUND CONTAINERS
WHEN TRANSFERRING LIQUID.
Other Precautions:"EMPTY" CONTAINERS RETAIN RESIDUE AND CAN BE
DANGEROUS. DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL OR
EXPOSE SUCH CONTAINERS TO HEAT, FLAME, SPARKS. THEY MAY EXPLODE AND
CAUSE INJURY/DEATH. AV OID REPEATED OR PROLONGED SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NON REQUIRED UNDER NORMAL CONDITIONS. IF HIGH
VAPOR OR MIST CONCENTRATIONS EXPECTED, USE NIOSH-APPROVED
RESPIRATOR FOR ORGANIC VAPORS AND MISTS. WEAR SUPPLIED-AIR
RESPIRATOR PROTECTION IN CONFINED OR ENCLOSED SPACES, IF NEEDED.
Ventilation:MECHANICAL (GENERAL AND/OR LOCAL EXHAUST, EXPLOSION-PROOF)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER, WORK
CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. AVOID BREATHING VAPORS. DO NOT GET IN EYES.
Supplemental Safety and Health
FORMULA CHANGED. FOR PREVIOUS FORMULATION, SEE PNI A, SAME NSN.
================== Physical/Chemical Properties ==================
HCC:F4
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:>300F,>149C
Melt/Freeze Pt:M.P/F.P Text:NOT KNOWN
Vapor Density:>1
Spec Gravity:0.960
Evaporation Rate & Reference:<1 (ETHER=1)
Appearance and Odor:LIQUID, SOLVENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, SPARKS, HOT SURFACES, STATIC
ELECTRICITY, OPEN FLAMES AND OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:FUMES, SMOKE, CARBON MONOXIDE, CARBON
DIOXIDE AND VARIOUS HYDROCARBONS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES. DISPOSAL MUST BE MADE
IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND
REGULATIONS. INCINERATION IS RECOMMENDED.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:KRYLON 1903 METALLIC BLUE (NEW FORMULA)
CAGE:EO688
CAGE:86142
CAGE:EO688
============= Composition/Information on Ingredients =============
Ingred Name:N-BUTYL ALCOHOL (SARA III)
CAS:71-36-3
RTECS #:EO1400000
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 8-17%
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 6-14%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 2-3%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 36.5%
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:INH:MAY BE HARMFUL;LIQ/VAP MAY IRRIT
NOSE,THROAT,LUNGS. SKIN/EYES:IRRIT. INGEST:MAY BE HARMFUL
======================= First Aid Measures =======================
First Aid:INGEST:DO NOT INDUCE VOMITING;CALL PHYSICIAN IMMED.
SKIN:IMMED FLUSH W/WATER FOR AT LEAST 15MIN;IF IRRIT PERSISTS,CALL
A PHYSICIAN. EYES:IMMED FLUSH W/WATER 15MIN W/EYELIDS APART;CALL
MD. INH:REMOVE T O FRESH AIR;GIVE ARTIF, RESP OR 0*2 IF NEC;CALL MD
===================== Fire Fighting Measures =====================
Flash Point:N/A AEROSOL
Extinguishing Media:DRY CHEMICAL,CO*2,FOAM. WATER MAY BE INEFFECTIVE
Fire Fighting Procedures:USE WATER TO COOL FIRE EXPOS CANS. WEAR SCBA
Unusual Fire/Explosion Hazard:EXTREM FLAM;UNDER PRESSURE. HI TEMP MAY
BURST CANS;AVOID ALL HEAT/IGNIT SOURCES,DIRECT SUN.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. SOAK UP
W/ABORSENT MATERIAL & REMOE TO A CHEMICAL DISPOSAL AREA. PREVENT
ENTRY INTO NATURAL BODIES OF WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE AT TEMPERATURES OER 120F.
WASH THOROUGHLY AFTER HANDLING. AVOID PROLONGED OR REPEATED CONTACT
W/EYES,SKIN OR CLOTHIN.
Other Precautions:USE W/ADEQUATE VENTILATION. AVOID BREATHING VAPOR OR
MIST. HANDLE IAW GOOD INDUSTRIL HYGEINE & SAFETY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD RESP PROT DEPENDING ON
CONDITIONS OF USE/TLV EXPOS
Ventilation:LOAL EXHAUST IN VOLUME & PATTERN ADEQ TO KEEP BELOW TLV
Supplemental Safety and Health
DATE OF PREP:06/30/86. ADD INGRED: METHYL ISOBUTYL KETONE,2-4%;
2-PROPANOL 1-METHOXY-,ACETATE,7-8%; PROPANE,16-17%.
================== Physical/Chemical Properties ==================
HCC:V3
Vapor Density:>1.0
Spec Gravity:<WATER
Evaporation Rate & Reference:FASTER THAN BU AC
Solubility in Water:SLIGHT
Appearance and Odor:N/A, PRESSURIZED CAN - PSIG APPROX 60 AT 70F
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO,CO*2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL,STATE & FEDERAL
REQUIREMENTS. EMPTY CONTAINER: MAY CONTAIN EXPLOSIVE VAPORS. DO NOT
CUT,PUNCTURE OR WELD ON OR NEARBY. INCINERATION WILL CAUSE
CONTAINER TO BURST VIOLENTL Y.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MOBIL SUPER HEAVY DUTY BRAKE FLUID
CAGE:6G112
CAGE:6G112
============= Composition/Information on Ingredients =============
Ingred Name:POLYETHYLENE GLYCOL; POLYOXYETHYLENE; PEG 400; PEG 75; PEG
4000; PEG 8000 *97-2*
CAS:25322-68-3
RTECS #:TQ3500000
Fraction by Wt: 30-40%
Other REC Limits:10 MG/CUM
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RATS): >5 G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NO SIGNIFICANT EFFECTS EXPECTED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NON-TOXIC, NON-IRRITATING.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH THOROUGHLY W/WATER. SKIN: WASH W/SOAP & WATER.
INGESTION: DON'T INDUCE VOMITING. GIVE 1-2 GLASSES OF WATER. OBTAIN
MEDICAL ATTENTION IN ALL CASES. NOTE TO PHYSICIANS: MATERIAL IF
ASPIRATED INTO THE LUNGS MAY CAUSE CHEMICAL PNEUMONITIS. TREAT
APPROPRIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:250F
Extinguishing Media:CO2, FOAM, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:FOR ENCLOSED AREA USE SCBA. USE WATER TO KEEP
FIRE EXPOSED CONTAINERS COOL. WATER SPRAY MAY BE USED TO FLUSH AWAY
FROM EXPOSURE.(SEE SUPP)
Unusual Fire/Explosion Hazard:WATER/FOAM MAY CAUSE FROTHING.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB ON FIRE RETARDANT TREATED SAWDUST,
DIATOMACEOUS EARTH. SHOVEL UP & DISPOSE. PREVENTS LEAKS FROM
ENTERING STORM SEWERS/DRAINS & CONTACT W/SOIL.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE IN OPEN/UNLABELLED
CONTAINERS. STORE AWAY FROM STRONG OXIDIZING AGENTS/COMBUSTIBLE
MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL REQUIREMENTS UNDER ORDINARY
CONDITIONS OF USE & W/ADEQUATE VENTILATION.
Ventilation:NO SPECIAL REQUIREMENTS UNDER ORDINARY CONDITIONS OF USE &
W/ADEQUATE VENTILATION.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. GOOD PERSONAL HYGIENE PRACTICES SHOULD ALWAYS BE FOLLOWED.
Supplemental Safety and Health
FIRE PROC CONT'D: PREVENT RUNOFF FROM FIRE CONTROL/DILUTION FROM
ENTERING STREAMS, SEWERS/DRINKING WATER SUPPLY.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>450F
Vapor Pres:<0.1
Vapor Density:>2
pH:9
Solubility in Water:MODERATE
Appearance and Odor:LIGHT YELLOW LIQUID W/MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:STRONG OXIDATION
Hazardous Decomposition Products:CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AT AN APPROPRIATE WASTE DISPOSAL
FACILITY IAW/LOCAL, STATE & FEDERAL REGULATIONS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:HURRICANE HOMER 828
CAGE:60150
CAGE:60150
============= Composition/Information on Ingredients =============
Ingred Name:FURAN, TETRAHYDRO-; (TETRAHYDROFURAN) (CERCLA)
CAS:109-99-9
RTECS #:LU5950000
OSHA PEL:200 PPM
ACGIH TLV:200 PPM/250 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:CYCLOHEXANONE (CERCLA)
CAS:108-94-1
RTECS #:GW1050000
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:HYGIENE PRACT:LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRIT OF EYES, NOSE & THROAT;
DROWS, NARCOS, TREMORS, & OTHER CNS EFTS @ HIGH CONC, SKIN IRRIT,
DERM, & DEFAT. POSS LIVER & KIDNEY DMG. SIGNS & SYMPS OF
EXPOS:EYES:WATERING, BLURRED VISION, INFL AMM, & IRRIT WHICH CAN
RSLT IN CORNEAL INJURY. INHAL:NASAL & RESP IRRIT, DIZZ, NARCOSIS,
HDCH, NAUS, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:CNS DEPRESS, & UNCON. INGEST:NAUS,
VOMIT; CNS DEPRESS; IRRIT OF GI TRACT, LIVER & PARITONEAL WALL;
LUNG CONGESTION. SKIN: IRRIT. DERM. CHRONIC:RPTS HAVE ASSOC RPTD &
PRLNGD OCCUP OVEREXP TO S OLVS W/PERM BRAIN & NERV SYS DMG.
INTENTIONAL MISUSE BY DELIB CONC & INHALING CONTENTS OF PROD MAY BE
HARMFUL/FATAL.
Medical Cond Aggravated by Exposure:INDIVIDUALS W/PRE-EXISTING OR
CHRONIC DISEASES OF EYES, SKIN, RESP SYS, CARDIOVASCULAR SYS,
GASTROINTESTINAL SYSTEM, LIVER OR KIDNEYS MAY HAVE INCREASED
SUSCEPTABILITY OF EXCESSIVE EXPOSURES.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/LG AMTS OF WATER FOR @ LST 15 MINS. SEEK IMMED
MED ATTN. INHAL:REMOVE TO FRESH AIR. ADMIN OXYG/ARTF RESP AS
NEEDED. SEEK IMMED MED ATTN. INGEST:DO NOT INDUCE VOMIT. GIVE LG
AMTS OF WATER ONLY IF CONSCIOUS. SEEK IMMED MED ATTN.SKIN:WASH
W/SOAP & WATER. IF IRRIT OCCURS, SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:7F,-14C
Lower Limits:2%
Upper Limits:11.8%
Extinguishing Media:FOAM, DRY CHEMICAL, CO*2, OR WATER FOG.
Fire Fighting Procedures:NIOSH APPRVD SCBA & FULL PROT EQUIP . HAZ
DECOMP PRODS POSS. EVAC AREA. DIKE FIRE CTL AREA AS RUN-OFF MAY
CREATE ADDNL FIRE HAZ & ENVIRONMENTAL (SUPDAT)
Unusual Fire/Explosion Hazard:EXTREMELY FLAMM-VERY LOW FLASH POINT.
VAPS ARE HVR/AIR & MAY TRAVEL ALONG GROUND/TO LOW SPOTS @
CONSIDERABLE DIST TO SOURCE OF IGNIT RSLTG IN POTNTL (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT. USE ABSORB MATLS
TO PVNT FOOLING HAZARD & TO CONTAIN. VENTILATE AREA
W/NATURAL/EXPLO-PROOF, FORCED AIR VENT. AVOID FLUSHING INTO SEWERS,
DRAINS, WATERWAYS, & SOIL. WEAR PR OT CLTHG & NIOSH APPRVD RESP
PROT DURING CLEANUP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNR CLSD & UPRIGHT WHEN NOT IN
USE. DO NOT STORE NEAR HEAT, SPKS/OPEN FLAMES. AVOID PRLNGD/RPTD
CONT W/SKIN/CLTHG. DO NOT REUSE EMPTY CNTNRS.
Other Precautions:IF TRANSFERRING THIS LIQ MATL TO OTHER CNTNRS, GROUND
ALL CNTNRS TO AVOID STATIC ELECTRICITY BUILDUP & DISCHARGE WHICH
MAY IGNITE FLAMM VAPS. EMPTY CNTNRS MAY CONTAIN RESIDUES & VAPS;
TREAT AS IF FULL & OBSERVE ALL PROD PRECAUTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN CONFINED, POORLY VENTILATED AREAS, USE NIOSH
APPROVED AIR PURIFYING OR NIOSH APPRVD SUPPLIED AIR RESPIRATORS.
Ventilation:LOCAL EXHAUST:ACCEPTABLE. MECHANICAL (GENERAL):PREFERABLE.
SPECIAL:EXPLOSION-PROOF EQUIPMENT.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
COVERALLS RECOMMENDED.
Work Hygienic Practices:WHERE USE CAN RSLT IN SKIN CONT, WASH EXPOSED
AREAS THORO BEFORE EATING, DRINKING, SMKNG/LEAVING WORK AREA. (ING
3)
Supplemental Safety and Health
FIRE FIGHT PROC:CONTAM. COOL HEAT EXPOSED CNTNRS W/WATER. IF SPILL/LEAK
HAS NOT IGNITED, USE WATER SPRAY TO DISPERSE VAPORS. EXPLO
HAZ:FLASHBACK. BURNING LIQ MAY FLOAT ON WATER. HEAT MAY BUILD UP
PRES S & RUPTURE CLSD CNTNRS. CNDTNS TO AVOID:& BASIC CNDTNS.
CNDTNS TO AVOID (POLYM):CATIONIC INITIATORS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:151F,66C
Vapor Pres:140 @ 20C
Vapor Density:2.5
Spec Gravity:0.97 (H*2O=1)
Evaporation Rate & Reference:8 (ETHYL ACETATE =1)
Solubility in Water:60%
Appearance and Odor:GRAY LIQUID/PUNGENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS AND BASES.
Stability Condition to Avoid:CAN FORM POTNTLY EXPLO PEROXIDES UPON LONG
STANDING IN AIR. HEAT, SPKS, OPEN FLAMES, & STRONG OXIDIZING,
ACIDIC (SUPDAT)
Hazardous Decomposition Products:CO, CO*2, HCL AND FRAGMENTED
HYDROCARBONS.
Conditions to Avoid Polymerization:CAN OCCUR IN PRESENCE OF CATIONIC
INITIATORS SUCH AS SELECTED LEWIS ACIDS/STRONG PROTON ACIDS. KEEP
AWAY FROM (SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:RCRA CLASSIFIED HAZ WASTE. DISPOSE OF ABSORBED
MATLS & LIQUID WASTES IN APPROVED, CONTROLLED INCINERATION FACILITY
I/A/W LOCAL, STATE, AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BRAYCOTE 137
CAGE:HO868
CAGE:HO868
CAGE:98308
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 30-35%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9293
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED LIGHT
NAPHTHENIC
CAS:64742-53-6
RTECS #:PY8036000
Fraction by Wt: 10-15%
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:WASTE DISP METH:MAY BE DESTROYED BY LIQUID INCINERATION.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CAN CAUSE SEVERE IRRIT. PRLNGD/RPTD
SKIN CONTACT CAN CAUSE MODERATE IRRIT, DEFAT. EXCESS INHAL OF VAPS
CAN CAUSE NASAL/RESPIRATORY IRRITATION. MAY CAUSE GASTROINTESTINAL
IRRITATION; ASPIRATION INTO L UNGS MAY BE FATAL. EYE IRRITATION,
REDNESS, TEARING, BLURRED VISION. SKIN DERM, NASAL/RESP IRRIT (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:DIZZINESS, FATIGUE, NAUSEA, HEADACHE,
POSSIBLE UNCONSCIOUSNESS, AND ASHPHYXIATION. INGESTION MAY CAUSE
NAUSEA, VOMITING, DIARRHEA.
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH LARGE AMOUNTS OF CLEAN WATER FOR AT LEAST 15
MIN. CONTACT A PHYSICIAN IMMEDIATELY. SKIN:REMOVE CONTAMINATED
CLOTHING, WIPE MATERIAL FROM SKIN. WASH THOROUGHLY WITH SOAP AND
WATER. INHA L:REMOVE FROM AREA OF EXPOSURE. ADMINISTER OXYGEN IF
DEEMED NECESSARY. INGEST:DO NOT INDUCE VOMITING, ASPIRATION HAZARD.
CONSULT A PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>100F,>38C
Lower Limits:1.0
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, FOAM
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
USE WATER AS FOG/SPRAY TO COOL FIRE EXPOSED CNTNRS, WATER/FOAM MAY
CAUSE VIOLENT FROTHING, (SUPP DATA)
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & MAY TRAVEL ALONG
GROUND & POSS IGNITE AT DISTANT LOCATION. WARNING! COMBUST LIQ.
EMPTY CNTNRS MAY RETAIN PROD RESIDUE/VAP WHICH (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCE OF IGNIT. ALL CLEANUP
PERSONS MUST WEAR PROT EQUIP. ELIMINATE LEAKS & DIKE LG SPILLS TO
AVOID SPREADING OF MATL. PUMP LIQ PORTION AND ABSORB REMAINDER WITH
DRY INERT MATERIAL. STO RE IN CLOSED CNTNRS UNTIL DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:MAINTAIN AMBIENT TEMPS. AVOID
PRLNGD/RPTD BRTHG OF VAPS, MISTS, FUMES. KEEP CNTNR TIGHTLY CLSD.
DO NOT STORE NEAR HEAT/FLAMES/STRONG OXIDANTS.
Other Precautions:5 GAL. OR LARGER METAL CONTAINERS SHOULD BE GROUNDED
WHEN TRANSFERRING MATERIAL. MAINTAIN ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CHEMICAL CARTRIDGE RESPIRATOR OR SUPPLIED AIR
RESPIRATORY EQUIPMENT AS REQUIRED FOR CONCENTRATION EXCEEDING
OCCUPATIONAL EXPOSURE RECOMMEDATION.
Ventilation:NOT NORMALLY REQUIRED. LOCAL EXAUST, IN ADDITION TO GENERAL
VENTILATION WHEN OCCUPATIONAL EXPOSURE LIMIT IS EXCEEDED.
Other Protective Equipment:NORMAL WORKING CLOTHING.
Work Hygienic Practices:DO NOT WEAR CONTAMINATED CLOTHING. LAUNDER
BEFORE RE-USE OR DISCARD.
Supplemental Safety and Health
FIRE FIGHT PROC:ESPECIALLY IF SPRAYED ONTO HOT BURNING LIQ. EXPLO
HAZ:CAN IGNITE EXPLOSIVELY, DO NOT CUT, DRILL/WELD ON OR NEAR FULL
OR EMPTY CNTNRS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:2MMHG.@20C
Vapor Density:>AIR
Spec Gravity:0.87 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DARK LIQUID, PETROLEUM SOLVENT ODOR.
Percent Volatiles by Volume:30-35%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC MATERIALS, CO*2, CO, VARIOUS
HYDROCARBONS AND SULFUR COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:ALL RECOVERED MATL SHOULD BE PACKAGED, LABELED,
TRANSPORTED, & DISP OF OR RECLAIMED IN CONFORMACE W/GOOD
ENGINEERING PRACTICES. DISP OF BY METHOD IN COMPLIANCE W/LOC,
STATE, & FED REGS REGARDING HLTH, AIR & WATER POLLUTION. IF
PERMITTED, (ING 3)
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PRIMER WOOD AND FERROUS METAL, BROWN
Preparer's Name:FRED ARMSTRONG
CAGE:OBRN9
CAGE:33832
CAGE:OBRN9
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 36%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:OVEREXPOSURE-NAUSEA, HEADACHE,
DIZZINESS CAUSED BY OVER INHALATION.
Effects of Overexposure:OVEREXPOSURE-NAUSEA, HEADACHE, DIZZINESS CAUSED
BY OVER INHALATION.
Medical Cond Aggravated by Exposure:NONE GENERALLY KNOWN.
======================= First Aid Measures =======================
First Aid:EYE CONTACT: FLUSH WITH WATER 15 MINUTES OR UNTIL IRRITATION
SUBSIDES. IF IRRITATION PERSISTS, CALL A PHYSICIAN. SKIN CONTACT:
REMOVE CONTAMINATED CLOTHING & WASH THOROUGHLY WITH SOAP & WATER.
INHALAT ION: IF OVERCOME BY VAPORS, REMOVE TO FRESH AIR, CALL
PHYSICIAN. INGESTION: DO NOT INDUCE VOMITING, CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:103 F/40 C
Autoignition Temp:Autoignition Temp Text:473 F
Lower Limits:0.9
Upper Limits:7
Extinguishing Media:CARBON DIOXIDE, FOAM, WATER FOG, DRY CHEMICAL.
Fire Fighting Procedures:USE AIR SUPPLIED BREATHING EQUIPMENT FOR
ENCLOSED CONTAINERS WITH WATER SPRAY. AVOID BREATHING VAPORS OR
FUMES.
Unusual Fire/Explosion Hazard:IF LEAK OR SPILL HAS IGNITED, USE WATER
SPRAY TO DISPERSE THE VAPORS FROM FIRE FIGHTERS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. KEEP FROM HEAT,
SPARKS & OPEN FLAME. ADD ABSORBENT (SAND, EARTH, SAWDUST) TO SPILL.
VENTILATE AREA (OPEN WINDOWS, DOORS). LARGE SPILL; KEEP FROM
ENTERING SEWERS/WATERCOURS ES BY DIKING. ADVISE AUTHORITIES IF
PRODUCT ENTERS
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM IGNITION SOURCES. KEEP
IN COOL, DRY, WELL VENTILATED AREAS. AVOID DIRECT SUNLIGHT AND
EXTREME TEMPERATURES, HOT OR COLD.
Other Precautions:AVOID EYE, SKIN CONTACT, INHALATION, INGESTION OF
MISTS, SPRAY OR VAPORS. AVOID BREATHING SANDING OR BLASTING DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE HYDROCARBON VAPOR CANISTER FOR SUPPLIED AIR
RESPIRATOR IN CONFINED AREAS.
Ventilation:LOCAL EXHAUST-FACE VELOCITY 60 FPM. SPECIAL-USE ONLY WITH
ADEQUATE VENTILATION. MECHANICAL-USE EXPLOSION PROOF EQUIPMENT
Other Protective Equipment:USE CHEMICAL RESISTANT APRON OR CLOTHING.
Supplemental Safety and Health
AVOID EYE, SKIN CONTACT, INHALATION, INGESTION OF MISTS, SPRAY OR
VAPORS. AVOID BREATHING SANDING OR BLASTING DUST.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:308 F/155 C
Melt/Freeze Pt:M.P/F.P Text:0 F(-17.8C)
Decomp Temp:Decomp Text:600 F(316C)
Vapor Pres:<10 @ 68 F
Vapor Density:4.8 @ 77 F
Spec Gravity:1.26 (H20=1)
Viscosity:67-77F(25C)
Evaporation Rate & Reference:0.09 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:REDDISH BROWN LIQUID WITH KEROSENE ODOR
Percent Volatiles by Volume:58.6
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CAN REACT WITH OXIDIZING MATERIAL WHEN HEATED TO DECOMPOSITION.
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:ASSURE CONFORMITY WITH APPLICABLE DISPOSAL
REGULATIONS DISPOSE OF ABSORBED MATERIAL AT AN APPROVED DISPOSAL
SITE OR FACILITY. DISPOSE IN CONFORMITY WITH STATE AND FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ACRYWELD 7993 PART A, 07993-1
Kit Part:Y
Preparer's Name:NORMAN S WOLFROM
CAGE:96900
CAGE:96900
============= Composition/Information on Ingredients =============
Ingred Name:METHACRYLIC ACID, METHYL ESTER; (METHYL METHACRYLATE) (SARA
313) (CERCLA)
CAS:80-62-6
RTECS #:OZ5075000
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATING WHEN PROLONGED
INHALATION OCCURS; CAUSES EYES TO WATER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE PERSON TO FRESH AIR. GIVE OXYG IF BRTHG IS
DFCLT. OBTAIN IMMED MED ATTN. EYE:FLUSH THORO W/WATER FOR @ LEAST
15 MINS WHILE LIFTING UPPER & LOWER LIDS. GET IMMED MED ATTN.
INGEST:DRINK 1-2 GLASSES OF WATER. DO NOT INDUCE VOMIT.CONSULT
PHYS/POIS CTL CTR IMMED. SKIN:IMMED REMOVE CONTAMD CLTHG/SHOES.
WIPE EXCESS FROM SKIN & FLUSH W/PLENTY OF WATER FOR @ LEAST 15
MINS. USE SOAP (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:53.0F,11.7C
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, FOAM, CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED POSITIVE PRESSURE SCBA
& FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID ALL PERSONAL CONT. CONTAIN SPILL IF
POSS. WIPE UP OR ABSORB ON SUITABLE MATL & SHOVEL UP. CLEAN UP
W/SUITABLE VENTILATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:THIS PROD (OR COMPONENTS, IF A MIX) IS
NOT LISTED IN IARC MONO, NTP FOURTH ANNUAL RPT/CURRENT ACGIH TLVS
AS CARCIN/POTNTL CARCINOGEN.
Other Precautions:IT IS NOT REGULATED BY OSHA AS CARCINOGEN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN ABSENCE OF PROPER ENVIRONMENTAL CONTROL/VENT,
THEN NIOSH/MSHA APPRVD POS-PRESS BRTHG APPARATUS OR NIOSH/MSHA
APPRVD FULL-FACE RESPIRATOR W/APPRVD CANNISTER IS RECOMMENDED.
Ventilation:LOCAL EXHAUST RECOMMENDED.
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC:IF AVAIL/FOLLOW BY WASHING W/SOAP & WATER. DO NOT REUSE
CLTHG UNTIL THORO CLEANED. GET MED ATTN. CONTAMD LEATHER ARTICLES,
INCLDG SHOES, CANNOT BE DECONTAMD & SHOULD BE DESTROYED.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:200F,93C
Vapor Density:HVR/AIR
Spec Gravity:1.01
Evaporation Rate & Reference:N-BUTYL ACETATE
Solubility in Water:NOT KNOWN
Appearance and Odor:LIQUID
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:OXIDIZING AGENTS.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED INCIN/BURY IN LEGAL LANDFILL. HANDLE
IN COMPLIANCE WITH LOCAL, STATE, AND FEDERAL ENVIRONMENTAL
PROTECTION AGENCY REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BUTYL CELLOSOLVE;ETHYLENE GLYCOL MONOBUT.ET
CAGE:82925
CAGE:82925
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTOXYETHANOL
CAS:111-76-2
RTECS #:KJ8575000
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:ACUTE:NO DATA IS GIVEN BY MFR;MAY
IRRITATE EYES,SKIN AND RESPIRATORY;NAUSEA,HEADACHE. CHRONIC:NO DATA
GIVEN BY MFR;POSSIBLE DERMATITIS,LIVER OR KIDNEY DAMAGE.
Effects of Overexposure:SEE HEALTH HAZARDS DATA.
Medical Cond Aggravated by Exposure:PRE-EXISTING CONDITIONS MAY BE
WORSEN BY MFR.
======================= First Aid Measures =======================
First Aid:EYES:WASH WITH PLENTY OF WATER;CALL A PHYSICIAN IF NEEDED.
SKIN:WASH THOROUGHLY WITH PLENTY OF WATER. INHALATION:REMOVE TO
FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:141F/61C
Lower Limits:1.1
Upper Limits:12.7
Extinguishing Media:WATER SPRAY,CO*2,DRY CHEMICAL,FOAM
Fire Fighting Procedures:NONE NOTED;USE NIOSH/MSHA APPROVED SCBA IN AN
ENCLOSED AREA.
Unusual Fire/Explosion Hazard:NONE NOTED
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;CONTAIN FREE
LIQUID;USE SUITABLE ABSORBENT MATERIAL AND RECOVER FOR PROPER
DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY AND WELL VENTILATED
AREA;KEEP AWAY FROM HEAT,FLAMES,CORROSIVE OR OXIDIZERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC
VAPOR/MIST IF ABOVE TLV/PEL.
Ventilation:LOCAL EXHAUST/GENERAL TO MAINTAIN PEL/TLV.
Other Protective Equipment:APRON,BOOTS,EYE WASH
Work Hygienic Practices:AVOID CONTACT WITH EYES,SKIN AND USE CARE.DO
NOT BREATHE VAPORS/MIST.
Supplemental Safety and Health
MSDS RECEIVED:APRIL 29,1988.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:340F/171C
Vapor Pres:0.6
Vapor Density:4.07
Spec Gravity:0.91
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR SEDIMENT FUEL,GLYCOL ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:EXTREME HEAT
Hazardous Decomposition Products:NOT GIVEN BY MFR
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF COLLECTED MATERIAL IN ACCORDANCE WITH
LOCAL,STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:1420-0253,SEALED LEAD BATTERY CLOSED CYLIND
CAGE:19209
CAGE:0FTM0
INC)
CAGE:19209
CAGE:28480
CAGE:9X866
============= Composition/Information on Ingredients =============
Ingred Name:SULFURIC ACID (SARA III)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 21%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:LEAD (SARA III) TOTAL PERCENTAGE OF INGREDIENTS 2 AND 3 IS
69.
CAS:7439-92-1
RTECS #:OF7525000
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.05 MG/M3;1910.1025
ACGIH TLV:0.15 MG/M3;DUST 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:LEAD OXIDE/LEAD OXIDE PASTE
CAS:1317-36-8
RTECS #:OG1750000
Other REC Limits:NONE SPECIFIED
Ingred Name:NON-HAZARDOUS INGREDIENTS (INERT)
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:UNKNOWN IARC:YES OSHA:NO
Health Hazards Acute and Chronic:IF BATTERY LEAKS/BROKEN:ACUTE-LEAD MAY
CAUSE GI UPSET,LOSS OF APPETITE,DIARRHEA,CONSTIPATION,CRAMPING &
FATIGUE.CONTACT WITH SULFURIC ACID WILL BURN EYES,SKIN &
RESPIRATORY TRACT & CAUSES CORNEAL & LU NG DAMAGE.CHRONIC-LEAD MAY
CAUSE ANEMIA,KIDNEY & NERVOUS SYSTEM DAMAGE.ACID CAN CAUSE
BRONCHITIS,EROSION OF TOOTH ENAMEL
Explanation of Carcinogenicity:CONTAINS LEAD.
Effects of Overexposure:IF BATTERY LEAKS/BROKEN: LEAD MAY CAUSE GI
UPSET, LOSS OF APPETITE, DIARRHEA, CONSTIPATION, CRAMPING &
FATIGUE. CONTACT WITH SULFURIC ACID WILL BURN EYES, SKIN &
RESPIRATORY TRACT & CAUSES CORNEAL & L UNG DAMAGE. LEAD MAY CAUSE
ANEMIA, KIDNEY & NERVOUS SYSTEM DAMAGE. ACID CAN CAUSE BRONCHITIS,
EROSION OF TOOTH ENAMEL.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS OR EYE PROBLEMS OR IMPAIRED KIDNEY OR RESPIRATORY
FUNCTION MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THE SUBSTANCE.
======================= First Aid Measures =======================
First Aid:OBTAIN MEDICAL ATTENTION IN ALL CASES OF
EXPOSURE.EYES/SKIN:FLUSH WITH WATER FOR 15 MINUTES.KEEP EYELIDS
OPEN.INHALATION:MOVE TO FRESH AIR.INGESTION:DO NOT INDUCE
VOMITING.CALL PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:CARBON DIOXIDE OR DRY CHEMICAL. USE WATER SPRAY TO
COOL FIRE EXPOSED CONTAINERS.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS WITH FULL
FACEPIECE OPERATED IN THE POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:HYDROGEN GAS IS PRODUCED IN THE CELLS
DURING NORMAL BATTERY OPERATION. THEY ENTER THE AIR THROUGH THE
VENT CAPS. KEEP AWAY SPARKS/SOURCES OF FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID CONTACT WITH SULFURIC ACID ELECTROLYTE
FROM BATTERY. LIME OR SODA MAY BE USED TO NEUTRALIZE AFTER DILUTING
WITH WATER. CONTAIN LARGER SPILLS WITH SAWDUST OR OTHER ABSORBING
CLOTHING.
Neutralizing Agent:SODIUM BICARBONATE SOLUTION (1 LB TO 1 GAL
WATER)-LIME OR SODA ASH
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE-STORE IN COOL DRY WELL
VENTILATED AREA.MAKE CERTAIN VENT CAPS ARE ON TIGHTLY.DO NOT
DOUBLE-STACK BATTERIES.
Other Precautions:KEEP TERMINALS COVERED IN PLASTIC CASE. AVOID
SHORTING BATTERIES. DO NOT CRACK OR OVERCHARGE BATTERIES. KEEP
LIGHTED CIGARETTES, SPARKS, AND FLAMES AWAY FROM CHARGING
BATTERIES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER NORMAL USE. USE
NIOSH-APPROVED ACID-MIST FILTER RESPIRATOR IF 1 MG/M3 TWA IS
EXCEEDED (ACID).
Ventilation:ADEQUATE GENERAL VENTILATION
Other Protective Equipment:RUBBER APRON AND BOOTS.EYES WASH STATION AND
SAFETY SHOWER. USE ACID-PROOF CLOTHING FOR MAJOR SPILLS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:Z4
Appearance and Odor:BATTERY, NON SPILLABLE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, STRONG ALKALIS
Stability Condition to Avoid:HIGH HEAT, OVERCHARGING, SPARKS AND FIRE
Hazardous Decomposition Products:OXIDES OF LEAD AND SULFUR, HYDROGEN,
SULFUR DIOXIDE AND SULFUR TRIOXIDE MAY FORM.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL ENVIRONMENTAL REGULATIONS FOR ACID OR LEAD SCRAP.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:1173 OUTBOARD, TWO-CYCLE OIL TCW-II 122010.
CAGE:1L506
CAGE:4N760
CAGE:1L506
============= Composition/Information on Ingredients =============
Ingred Name:LUBRICATING BASE OIL CONTAINING ONE OR MORE OF INGREDIENTS
#2 THRU 5.
> Wt:60.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:SOLVENT DEWAXED RESIDUAL OIL
CAS:64742-62-7
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 AS OIL MIST
ACGIH TLV:5 MG/M3 AS OIL MIST
Ingred Name:RESIDUAL OILS, HYDROTREATED (HYDROTREATED BOTTOMS).
CAS:64742-57-0
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:DISTILLATES, HYDROTREATED HEAVY PARAFFINIC
CAS:64742-54-7
RTECS #:PY8035500
Other REC Limits:NONE RECOMMENDED
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:DISTILLATES, SOLVENT-DEWAXED HEAVY PARAFFINIC
CAS:64742-65-0
RTECS #:PY8038500
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 AS OIL MIST
ACGIH TLV:5 MG/M3 AS OIL MIST
Ingred Name:DISTILLATES, HYDROTREATED LIGHT
CAS:64742-47-8
= Wt:20.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:ADDITIVES
Minumum % Wt:1.
Maxumum % Wt:5.
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ACGIH TLV 5MG/M3 FOR MINERAL OIL MIST.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NO PRODUCT TOXICOLOGY DATA AVAILABLE.
THE HAZARD EVALUATION WAS BASED ON DATA FROM SIMILAR MATERIALS.
Explanation of Carcinogenicity:PER MSDS NONE OF THE OILS ARE LISTED IN
NTP, IARC, OSHA AS CARCINOGENIC.
Effects of Overexposure:NONE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE-FLUSH WITH FRESH WATER FOR 15 MIN. HOLD EYE LIDS OPEN.
REMOVE CONTACT LENSES IF WORN. SEE DOCTOR FOR IRRITATION. SKIN-AS A
PRECAUION, WASH SKIN WELL W/SOAP & WATER. REMOVE CONTAMINATED
CLOTHING. I NGEST-GIVE WATER OR MILK & CALL FOR MEDICAL AVICE.
DON'T INDUCE VOMIT UNLESS DIRECTED BY MEDICAL PERSONNEL. TAKE
PERSON & PRODUCT CONTAINER TO HOSPITAL. INHALE-MOVE PERSON TO FRESH
AIR.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:=80.C, 176.F
Lower Limits:NDA
Upper Limits:NDA
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:FOR FIRES INVOLVING THIS MATERIAL DON'T ENTER
ENCLOSED/CONFINED FIRE SPACE W/O PROPER PTORECT EQUIPMENT,
INCLUDING SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:LIQUID EVAPORATES & FORMS VAPOR WHICH CAN
CATCH FIRE & BURN WITH EXPLOSIVE VIOLENCE. INVISIBLE VAPOR SPREADS
EASILY & CAN BE SET ON FIRE BY IGNITION SOURCES.
================== Accidental Release Measures ==================
Spill Release Procedures:CALL 800-424-9300(CHEMTREC). STOP THE SOURCE
OF THE LEAK OR RELEASE. CLEANUP RELEASE AS SOON AS POSSIBLE.
CONTAIN LIQUID TO PREVEN FURTHER CONTAMINATION OF SOIL, WATER OR
GROUNF WATER. CLEAN UP SMALL SPILL BY USING SORBENT MATERIAL OR
PUMPING.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT USE OR STORE NEAR FLAME, SPARKS
OR HOT SURFACES. USE ONLY IN WELL VENTILATED AREA. KEEP CONTAINER
CLOSED.
Other Precautions:DO NOT WELD, HEAT OR DRILL CONTAINER. RESIDUE MAY
IGNITE WITH EXPLOSIVE VIOLENCE IF HEAT SUFFICIENTLY. CAUTION! DO
NOT USE PRESSURE TO EMPTY DRUM OR DRUM MAY RUPTURE WITH EXPLOSIVE
FORCE. READ & OBSER VE ALL PRECAUTIONS ON PRODUCT LABEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL RESPIRATORY PROTECTION IS NORMALLY
REQUIRED. HOWEVER, IF OPERATING CONDITIONS CREATE HIGH AIRBORNE
CONCENTRATINS, THE USE OF AN APPROVED RESPIRATOR IS RECOMMENDED.
Ventilation:USE ADQUATE VENTILATION TO KEEP AIRBORNE CONCENTRATIONS OF
THIS MATRL BELOW THE RECOMMENDED EXPOSURE STANDARD.
Other Protective Equipment:AVOID PROLONG/REPEAT SKIN CONTACT. CAN BE
MINIMIZED BY WEARING PROTECTIVE CLOTHING. AVOID MATERIAL GETTING
INTO EYES.
Work Hygienic Practices:WASH HANDS AFTER HANDLING. LAUNDRY CONTAMINATED
CLOTHING PRIOR TO REUSE.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:NDA
Melt/Freeze Pt:M.P/F.P Text:NDA
Decomp Temp:Decomp Text:NDA
Vapor Pres:NDA
Vapor Density:NDA
Spec Gravity:0.87
pH:NDA
Viscosity:25 CST @ 40C
Evaporation Rate & Reference:NDA
Solubility in Water:INSOLUBLE.
Appearance and Odor:NDA
Percent Volatiles by Volume:NDA
Corrosion Rate:NDA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY REACT W/STRONG OXIDIZING AGENTS SUCH AS CHLORATES, NITRATES,
PEROXIDES, ETC.
Stability Condition to Avoid:NDA
Hazardous Decomposition Products:NDA
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE CONTAMINATED MATERIALS IN DISPOSABLE
CONTAINERS & DISPOSE OF IN A MANNER CONSISTENT W/APPLICABLE
REGULATIONS. CONTACT LOCAL ENVIRONMENTAL OR HEALTH AUTHORITIES FOR
APPROVED DISPOSAL OF THIS MATE RIAL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:2,6-LUTIDINE, 204757
CAGE:IO030
CAGE:30060
CAGE:IO030
============= Composition/Information on Ingredients =============
Ingred Name:2,6-LUTIDINE
CAS:108-48-5
RTECS #:OK9700000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITANT. TOXIC BY INGESTION,
INHALATION OR DERMAL ABSORPTION. SIGNS AND SYMPTOMS OF EXPOSURE:
IRRITATION, HEADACHE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST: IF WITHIN 15 MINUTES AFTER OCCURRENCE, MAKE PATIENT
DRINK 1 OR 2 GLASSES OF WATER. ALWAYS CALL MD. EYES: RINSE
LIBERALLY WITH WATER FOR AT LEAST 15 MIN. SEND OR BRING PATIENT TO
MD OR HOSPITAL . INHAL: TAKE PATIENT INTO THE FRESH AIR & ALLOW TO
REST. ALWAYS CALL MD.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:93.0F,33.9C
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NO RISK OF EXPLOSION.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB THE LIQUID IN DRY SAND, DIATOMITE,
VERMICULITE, ETC., SHOVEL THE MIXTURE INTO PLASTIC BAGS AND REMOVE
TO THE CENTRAL DEPOT FOR CHEMICAL WASTE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
USE A HOOD.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED VAPOR MASK.
Ventilation:LOCAL EXHAUST SYSTEM REQUIRED.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:291F,144C
Melt/Freeze Pt:M.P/F.P Text:>16F,>-9C
Vapor Pres:87 @ 79C
Spec Gravity:0.9252 @ 20C
Solubility in Water:MISCIBLE
Appearance and Odor:LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF NO*X.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS . INCINERATE.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: TITANIUM PUTTY RESIN, DE036
Cage: 16059
Resp. Party Other MSDS No.: 0619, PART NO. 0113
=======================================================
Contractor Summary
=======================================================
Cage: 16059
=======================================================
Ingredients
=======================================================
Cas: 25068-38-6
RTECS #: CE6880000
% low Wt: 25.
% high Wt: 50.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50: (ORAL,RAT): 30 G/KG
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: SKIN: MODERATE IRRITANT. CONTACT AT ELEVATED
TEMPERATURES CAN CAUSE THERMAL BURNS. MAY CAUSE SKIN SENSITIZATION (RASHES,
HIVES). EYES: MODERATE IRRITANT. CONTACT AT ELEVATED TEMPERATURES CAN CA USE
THERMAL BURNS. INHAL: THE LOW VAPOR PRESSURE OF RESIN MAKES INHAL UNLIKELY IN
NORMAL USE. INGEST: ACUTE ORAL TOXICITY IS LOW. MAY CAUSE GASTRIC DISTRESS.
CHRONIC: RPLNGD/RPTD SKIN CONTACT MAY CAUS E SENSITIZATION, WITH ITCHING,
SWELLING, OR RASHES ON LATER EXPOSURE. OTHER CHRONIC EFTS: 2-YEAR BIOASSAYS
IN MICE EXPOSED BY DERMAL ROUTE TO EPON 828, DGEBPA OR OTHER COMMERCIAL
RESINS YIELDED (EFTSOF OVEREXPOSURE)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: EFTS OF OVEREXP: LIMITED EVIDENCE OF WEAK
CARCINOGENICITY. THE AUTHORS CONCLUDED THAT THE RENAL TUMOR EVIDENCE WITH
EPON 828 "WAS OF NO BIOLOGICAL SIGNIFICANCE: AND THAT THE RESIN "IS NOT A
SYSTEMIC C ARCINOGEN WHEN APPLIED TO THE DORSAL SKIN OF CF1 MICE."
Medical Cond Aggravated By Exposure: PREEXISTING EYE AND SKIN DISORDERS.
DEVELOPMENT OF PREEXISTING SKIN OR LUNG ALLERGY SYMPTOMS MAY INCREASE.
First Aid: EYES: FLUSH W/CLEAN WATER FOR AT LST 15 MINS WHILE GENTLY HOLDING
EYELIDS OPEN. GET IMMED MED ATTN. SKIN: IMMED REMOVE CONTAMD CLTHG &
EXCESS CONTAMINANT. FLUSH W/WATER. WASH THORO W/SOAP & WARM WATER .
CONSULT PHYS IF IRRIT DEVELOPS. INHAL: REMOVE TO FRESH AIR. ADMIN OXYG IF
BRTHG IS DFCLT. GET MED ATTN IF SYMS PERSIST. INGEST: DO NOT INDUCE VOMIT.
GIVE 2 GLASSES OF WATER TO DILUTE IF PATIENT IS C ONSCIOUS. GET MED ATTN. NOT
TO PHYS: IN GENERAL, EMESIS INDUCTION IS UNNECESSARY IN HIGH VISCOSITY, LOW
VOLATILITY PRODUCTS, E.G., NEAT EPOXY RESINS.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: AVOID PERSONAL CONT. ELIM IGNIT SOURCES. VENTILATE
AREA. DIKE, CNTN & ABSORB W/CLAY, SAND OR OTHER SUITABLE MATL. FOR LG
SPILLS, PUMP TO STOR/SALVAGE VESSELS. SOAK UP RESIDUE W/ABSORB SUCH AS CLAY,
SA ND/OTHER SUITABLE MATL & DISPOSE OF PROPERLY. FLUSH AREA W/WATER TO
REMOVE TRACE RESIDUE. PVNT SPILL FROM ENTERING DRAINAGE/SEWER SYSTEMS,
WATERWAYS, AND SURFACE WATER.
Neutralizing Agent: NOT RELEVANT.
Waste Disposal Methods: IF THIS RESIN BECOMES A WASTE, IT WOULD NOT BE A
HAZARDOUS WASTE BY RCRA CRITERIA (40CFR 261). DISPOSE OF ACCORDING TO
APPLICABLE FEDERAL, STATE, AND LOCAL REGULATIONS.
Handling And Storage Precautions: AVOID CONTACT W/SKIN, EYES/CLOTHING. WASH
THOROUGHLY W/SOAP & WATER AFTER USING & PARTICULARLY BEFORE EATING,
DRINKING, SMKNG, APPLYING COSMETICS/USING TOILET FACILITIES. LAUNDER CONTAMD
CLTHG & PROT GEAR BEFORE REUSE. DISCARD CONTAMD LEATHER ARTICLES.
Other Precautions: HNDL MIXED RESIN & HARDENER I/A/W POTNTL HAZARD OF
CURING AGENT USED. PROVIDE APPROP VENT/NIOSH APPRVD RESP PROT AGAINST DECOMP
PRODS (SEE STABILITY & REACTIVITY SECTION) DURING WELDING/FLAME CUTTING
OPERATIONS & TO PROTECT AGAINST NUISANCE DUST DURING SANDING/GRIND OF
CURED PROD. (SUPDAT)
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point: >204.4C, 400.F
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, AND FOAM.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). MATERIAL WILL NOT BURN UNLESS PREHEATED. COOL FIRE EXPOSED
CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard: HEATING >300F IN PRESENCE OF AIR MAY CAUSE
SLOW OXIDATIVE DECOMP & >500 F MAY CAUSE POLYMERIZATION. WHEN HEATED
TO DECOMP IT EMITS FUMES OF CL-, CARBON MONOXIDE, OTHER FUMES & VAPORS
VARYING IN COMPOS ITION AND TOXICITY.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE REQUIRED AT NORMAL HNDLING TEMPERATURES AND
CONDITIONS. USE NIOSH APPROVED ORGANIC VAPOR CARTRIDGES FOR UNCURED RESIN AND
NIOSH APPROVED DUST/PARTICLE RESPIRATORS DURING GRINDING/SANDING OPERATIO NS
OF CURED RESIN AS EXPOSURE LEVELS DICTATE.
Ventilation: LOCAL EXHST VENT IS PREFERRED ALTHOUGH GOOD GEN MECH VENT IS
USUALLY ADEQ FOR MOST INDUST APPLICATIONS. LOCAL EXHST IS REC FOR CONFINED
AREAS.
Other Protective Equipment: EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA (FP N). OTHER GEAR AS REQUIRED TO PREVENT SKIN CONTACT.
Work Hygienic Practices: WASH THOROUGHLY WITH SOAP & WATER AFTER USING &
PARTICULARLY BEFORE EATING, DRINKING, SMOKING, APPLYING COSMETICS, OR USING
TOILET FACILITIES.
Supplemental Safety and Health: OTHER PREC: STORE IN A COOL, DRY AREA AWAY FROM
HIGH TEMPERATURES AND FLAMES. CNDTNS TO AVOID (POLYMER): GENERATING
UNIDENTIFIED FUMES AND VAPORS WHICH MAY BE TOXIC.
=======================================================
Physical/Chemical Properties
=======================================================
Boiling Point: >260.C, 500.F
Vapor Pres: 0.03 MM HG AT 171F
Vapor Density: >1(AIR=1)
Spec Gravity: 1.1-1.3
PH: SEE OTHER INFO
Solubility in Water: NEGLIGIBLE
Appearance and Odor: VISCOUS LIQUID WITH LITTLE ODOR.
Percent Volatiles by Volume: 0
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: OPEN FLAME AND EXTREME HEAT.
Materials To Avoid: STRONG LEWIS OR MINERAL ACIDS, STRONG OXIDIZING AGENTS,
STRONG MINERAL AND ORGANIC BASES (ESPECIALLY PRIMARY AND SECONDARY ALIPHATIC
AMINES).
Hazardous Decomposition Products: OXIDES OF CARBON; ALDEHYDES, ACIDS AND OTHER
ORGANIC SUBSTANCES MAY BE FORMED DURNG COMBUSTION OR ELEVATED TEMPERATURE
(>500 DEG F) DEGRADATION.
Hazardous Polymerization Indicator: YES
Conditions To Avoid Polymerization: HEAT IS GENERATE WHEN RESIN IS MIXED
W/CURING AGENTS; RUN-A-WAY CURE RXNS MAY CHAR & DECOMPOSE RESIN, (SUPDAT)
=======================================================
Toxicological Information
=======================================================
Toxicological Information: BOTH RESIN & DIGLYCIDYL ETHER OF BISPHENOL (A
COMPONENT OF THIS PROD) HAVE PROVED TO BE INACTIVE WHEN TESTED BY IN VIVO
MUTAGENICITY ASSAYS. BOTH HAVE SHOWN ACTIVITY BY IN VITRO MICROBIAL
MUTAGENICITYSCREENING AND HAVE PRODUCED CHROMOSOMAL ABERRATIONS IN CULTURED
RAT LIVER CELLS. ORAL LD50 (MOUSE) = 15.6 G/KG
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: PH:NEUTRAL (5% SOLUTION OR SLURRY IN WATER. VOC
(GRAMS/LITER): 0
=======================================================
HAZCOM Label
=======================================================
Product ID: TITANIUM PUTTY RESIN, DE036
Cage: 16059
Company Name: DEVCON CORP
Street: 30 ENDICOTT ST
Zipcode: 01923-3753
Label Required IND: Y
Date Of Label Review: 09/09/1999
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: None
Contact Hazard: Moderate
Fire Hazard: Slight
Reactivity Hazard: Slight
Hazard And Precautions: HAZ POLYMERIZATION MAY OCCUR. ACUTE: SKIN: MODERATE
IRRITANT. CONTACT AT ELEVATED TEMPERATURES CAN CAUSE THERMAL BURNS. MAY CAUSE
SKIN SENSITIZATION (RASHES, HIVES). EYES: MODERATE IRRITANT. CONTACT A T
ELEVATED TEMPERATURES CAN CAUSE THERMAL BURNS. INHAL: THE LOW VAPORPRESSURE
OF RESIN MAKES INHAL UNLIKELY IN NORMAL USE. INGEST: ACUTE ORAL TOXICITY IS
LOW. MAY CAUSE GASTRIC DISTRESS. CHRONIC: RPLN GD/RPTD SKIN CONTACT MAY CAUSE
SENSITIZATION, WITH ITCHING, SWELLING, OR RASHES ON LATER EXPOSURE. POSSIBLE
CARCINOGEN.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FA7558
CAGE:JO764
CAGE:81831
CAGE:JO764
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR.AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UNC ONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SAG 10 SILICONE ANTIFOAM EMULSION
CAGE:GO055
CAGE:GO055
CAGE:87664
============= Composition/Information on Ingredients =============
Ingred Name:VOLATILE ORGANIC CONTENT: 5.98/33.61 G/L LESS WATER &
EXEMPT CPDS.
RTECS #:9999999VO
Ingred Name:POLYDIMETHYL SILOXANE EMULSION PLUS PROPRIETARY ADDITIVES
Fraction by Wt: <50%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: >50%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: LIQUID & MIST MAY CAUSE
IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR IF NOT BREATHING.
EYES: IMMEDIATELY FLUSH W/RUNNING WATER FOR 15 MINS. SKIN: WASH
W/LOTS OF SOAP & WATER. INGESTION: IF CONSCIOUS, IMMEDIATELY INDUCE
VOMITING BY GIVING 2 GLASSES OF WATER & STICKING FINGER DOWN THE
THROAT. DON'T GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
OBTAIN MEDICAL ATTENTION IN A LL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRES.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NON-COMBUSTIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE CLOTHING/RUBBER
RESPIRATOR. SMALL: MOP/WIPE UP & DISPOSE OF IN DOT-APPROVED WASTE
CONTAINERS. LARGE: CONTAIN BY DIKING W/ SOIL/NON-COMBUSTIBLE
SORBENT.(SEE SUPP)
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY WELL VENTILATED
AREA. KEEP CONTAINER TIGHTLY CLOSED WHEN NOT IN USE. DON'T PRESSURE
TO EMPTY CONTAINER.
Other Precautions:DON'T GET IN EYES, ON SKIN/CLOTHING. CONTAINERS EVEN
THOSE THAT ARE EMPTY, WILL RETAIN PRODUCT RESIDUE & VAPORS. ALWAYS
OBEY HAZARD WARNINGS & HANDLE EMPTY CONTAINERS AS IF THEY WERE
FULL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED.
Ventilation:GENERAL ROOM VENTILATION.
Other Protective Equipment:LONG-SLEEVED SHIRT/TROUSERS/SAFETY
SHOES/EYEWASH, SAFETY SHOWER.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING/SHOES
BEFORE REUSE.
Supplemental Safety and Health
SPILLS CONT'D: SMALL: FULL FACEPIECE AIR-PURIFYING CARTRIDGE RESPIRATOR
EQUIPPED FOR ORGANIC VAPORS MAY BE SATISFACTORY. ALWAYS WEAR EYE
PROTECTION. LARGE: THEN PUMP INTO DOT-APPROVED WASTE CONTAINERS
/ABSORB W/NON-COMBUSTIBLE SORBENT MATERIAL/PLACE RESIDUE IN
DOT-APPROVED WASTE CONTAINERS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F
Melt/Freeze Pt:M.P/F.P Text: 32F
Vapor Pres:>0.05
Vapor Density:>1
Spec Gravity: 1
Evaporation Rate & Reference:(BU AC =1): 0
Solubility in Water:DISPERSIBLE
Appearance and Odor:MILKY WHITE LIQUID W/MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER
Stability Condition to Avoid:MOIST AIR
Hazardous Decomposition Products:CO, CO2, OXIDES OF SILICONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF CONTAMINATED PRODUCT & MATERIALS USED
IN CLEANING UP SPILLS/LEAKS IN A MANNER APPROVED FOR THIS MATERIAL
& IAW/FEDERAL, STATE & LOCAL REGULATIONS. EMPTY CONTAINERS CAN HAVE
RESIDUES/GASES & MISTS ARE SUBJECT TO PROPER WASTE DISPOSAL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:3XX SERIES, 4XX SERIES STAINLESS STEEL
CAGE:11045
CAGE:11045
CAGE:1P361
============= Composition/Information on Ingredients =============
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: 60-88%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3 (TDUST)
ACGIH TLV:5 MG/M3 (OXIDE FUME)
Ingred Name:CHROMIUM (SARA 313) (CERCLA)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 10-30%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3; 9596
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:NICKEL (SARA 313) (CERCLA)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9596
Ingred Name:MANGANESE (SARA 313)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: <6%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C, 5 MG/M3 (FUME)
ACGIH TLV:0.2 MG/M3; 9596
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
Fraction by Wt: <6%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 PPM.
ACGIH TLV:10 PPM.
Ingred Name:COPPER (SARA 313) (CERCLA)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: <6%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2 MG/M3 FUME; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TITANIUM
CAS:7440-32-6
RTECS #:XR1700000
Fraction by Wt: <6%
Other REC Limits:NONE RECOMMENDED
Ingred Name:CARBON OR GRAPHITE, SYNTHETIC
CAS:7440-44-0
RTECS #:FF5250100
Fraction by Wt: <2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9596
Ingred Name:PHOSPHOROUS (YELLOW) (SARA 302/313) (CERCLA)
CAS:7723-14-0
RTECS #:TH3500000
Fraction by Wt: <2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.02 PPM; 9596
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SULFUR
CAS:7704-34-9
RTECS #:WS4250000
Fraction by Wt: <2%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: <2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9596
Ingred Name:COBALT (SARA 313)
CAS:7440-48-4
RTECS #:GF8750000
Fraction by Wt: <2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.02 MG/M3; A3; 9596
Ingred Name:NIOBIUM (ALSO CALLED COLUMBIUM)
CAS:7440-03-1
Fraction by Wt: <2%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
Fraction by Wt: <2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9596
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION OF WELDING FUMES MAY
CAUSE NERVOUS SYSTEM AND MUSCLE IRREGULARITIES, IRRITATION OF EYES,
NOSE, THROAT, AND RESPIRATORY SYSTEM, METAL FUME FEVER. CHRONIC:
INHALATION OF FUMES MAY CAUS E CANCER, SIDEROSIS, FLUOROSIS AND
AFFECT LUNG FUNCTION.
Explanation of Carcinogenicity:CONTAINS NICKEL WHICH IS LISTED BY BOTH
IARC AND NTP.
Effects of Overexposure:INHALATION: NAUSEA, DIZZINESS,DRYNESS OF NOSE
AND THROAT, COUGHING, WHEEZING AND SHORTNESS OF BREATH. EYES:
REDNESS, TEARING, BLURRED VISION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESUSCITATE IF NEEDED. EYES:
FLUSH WITH PLENTY OF WATER FOR 15 MINUTES. SEE DOCTOR. SKIN: WASH
WITH SOAP AND WATER. INGESTION: DO NOT INDUCE VOMITING. SEE DOCTOR.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:STEEL PRODUCTS IN THE SOLID STATE PRESENT NO
FIRE OR EXPLOSION HAZARD.
================== Accidental Release Measures ==================
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:REMOVE ANY COMBUSTIBLES FROM WORK
AREA: SPARKS OR WELDING ARC COULD IGNITE NEARBY COMBUSTIBLES.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR WELDING
FUMES OR SUPPLIED AIR RESPIRATOR IN CONFINED SPACES OR WHERE FUME
CONCENTRATION EXCEEDS REGULATORY LIMITS.
Ventilation:USE MECHANICAL OR LOCAL EXHAUST OR BOTH TO MAINTAIN LEVELS
OF FUMES BELOW REGULATORY LIMITS.
Other Protective Equipment:CLOTHING TO PROTECT ENTIRE BODY FROM SPARKS.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
RECENT EPIDEMIOLOGICAL STUDIES OF WORKERS MELTING AND WORKING ALLOYS
CONTAINING NICKEL/CHROMIUM HAVE FOUND NO INCREASE IN CANCER.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:>2600F,>142
Spec Gravity:7
Solubility in Water:INSOLUBLE
Appearance and Odor:GREY-BLACK SOLID; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTS WITH STRONG ACIDS TO PRODUCE HYDROGEN GAS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:METALLIC DUST OR FUMES MAY BE PRODUCED
DURING WELDING, BURNING, GRINDING AND POSSIBLY MACHINING.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CURENE 280, 11109
CAGE:ANDER
CAGE:ANDER
============= Composition/Information on Ingredients =============
Ingred Name:WASTE DISP METH: USUALLY CRUSHED AND LANDFILLED IN A
PERMITTED FACILITY.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:POSITIVE PRESSURE SELF-CONTAINED BREATHING
RTECS #:9999999ZZ
Ingred Name:BENZENAMINE, 4,4'-METHYLENEBIS(2-CHLORO-; (4,4'-METHYLENE
BIS (2-CHLOROANILINE))
CAS:101-14-4
RTECS #:CY1050000
Fraction by Wt: 40%
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:SUPP DATA: SYSTEMIC & OTHER EFTS: BASED ON AVAIL DATA FOR
4,4'-METHYLENE BIS (2-CHLOROANILINE) RPTD EXPOS MAY (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2:PRDCE CYANOSIS & CANCER. MAY EFT KIDNEY FUNC. FOLLOW
HAVE BEEN OBSERVED IN EXPERIMENTAL ANIMALS ONLY: (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:PULM CARCINOMA, MALIGNANT LIVER TUMORS, CARCINOMA OF
BREAST & METHEMOGLOBINEMIA.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: CLSD CONTRS & DISPOSED. MOLTEN MATL SHOULD BE
ALLOWED TO COOL BEFORE CLEAN-UP. DECONTAM AREA. (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:MINOR SPILL: PLACE INTO OPEN TOP CONTRS. DECONTAM
SPILL AREA. CLEAN-UP: DECONTAM FLOOR USING SUITABLE (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:SOLV SUCH AS DIMETHYL SULFOXIDE OR METHYLETHYL
KETONE. USE OF SOLV TO DECONTAM SPILL AREA MAY RSLT IN (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: GREATER DANGER DUE TO FLAMM VAPORS. USE APPROP PREC.
CARCINOGENICITY: MONOGRAPHS VOL SUPL 7, P.246, 1987 .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT)2,100 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: VAPS FROM HEATED PROD MAY
CAUSE IRRIT. SKIN: HAZ COMPONENTS ARE ABSORBED THRU SKIN.
4,4'-METHYLENEBIS-2-CHLOROANILINE MAY CAUSE CANCER BASED ON TESTS
IN LAB ANIMALS. MAY PRDCE CYANOSIS. M AY CAUSE ALLERGIC SKIN RXN IN
SUSCEPTIBLE INDIVIDUALS. PRLNGD/RPTD EXPOS MAY CAUSE IRRIT. INGEST:
MATL (EFTS OF OVEREXP)
Explanation of Carcinogenicity:4,4'-METHYLENEBIS-2-CHLOROANILINE: ANTIC
TO BE CARCIN, NTP 6TH ANNUAL RPT ON CARCINOGEN, 1991; GROUP 2A,
IARC (ING 8)
Effects of Overexposure:HLTH HAZ: MAY BE INGESTED THRU POOR HYGIENE
PRACT. MAY CAUSE GI & KIDNEY DAM. MAY PRDCE CYANOSIS. INHAL: MAY
PRDCE CYANOSIS. 4,4'-METHYLENEBIS-2-CHLOROANILINE MAY CAUSE CANCER
BASED ON TESTS IN LAB AN IMALS. MAY CAUSE RESP SENSIT IN
SUSCEPTIBLE INDIVIDUALS. @ ROOM TEMP, VAPS ARE MINIMAL DUE TO LOW
VAP PRESS. (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:RINSE W/WATER IMMED FOR @ LST 15 MIN.SEE PHYS. SEEK EMER
MED ATTN IMMED IF MOLTEN MATL ENTERS EYES. SKIN:REMOVE MATL OFF
EXPOSED AREAS. WASH RESIDUE OFF W/SOAP & WATER. SEE PHYS. OBTAIN
IMMED MED ATTN IF MOLTEN MATL IS SPILLED ON SKIN. INGEST:SEEK MED
ATTN IMMED. INHAL: REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE MOUTH TO
MOUTH RESUSCITATION.IF BRTHG IS DFCLT, GIVE OXYGEN & OBTAIN MED
HELP IMMED.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:>400F,>204C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, WATER OR FOAM.
Fire Fighting Procedures:NIOSH/MSHA APPROVED SELF-CONTAINED BREATHING
APPARATUS & FULL PROTECTIVE EQUIPMENT . DO NOT BREATHE VAPORS OR
FUMES, AVOID SKIN CONTACT.
Unusual Fire/Explosion Hazard:DOWNWIND PERS SHOULD BE EVACUATED. DO NOT
RESEAL CONTAMD CONTRS AS PRESS BUILD-UP MAY RUPTURE THEM. AVOID
SKIN CONT. PROD IS COMBUST & UNDER EXTREME (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:EVAC AREA & VENT SPILL AREA, DIKE SPILL TO
PVNT ENTRY INTO WATER SYS, WEAR FULL PROT EQUIP INCL NIOSH/MSHA
APPRVD RESP EQUIP DURING CLEAN-UP. MAJOR SPILL: IF DURING
TRANSPORTATION, CALL CHEM-TREC @ (8 00)424-9300. LG QTY MAY BE
SCOOPED UP INTO (ING 5)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE MATL IN ORIGINAL CONTRS. DO NOT
REUSE EMPTY CONTRS AS RESIDUE MAY BE HAZARDOUS. DO NOT CUT/USE
TORCH ON EMPTY CONTRS. ISOLATE STORAGE AREAS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ATM LEVELS SHOULD BE MAINTAINED BELOW EXPOS LIM.
WHEN RESP PROT IS NEEDED FOR CERTAIN OPERATIONS, USE ONLY
NIOSH/MSHA APPRVD ORG CARTRIDGE RESPS. FOR EMER & OTHER CNDTNS
WHERE OSHA LIM MAY BE GREATLY EXCEEDED, USE NIOSH/MSHA APPRVD (ING
10)
Ventilation:PROVIDE GENERAL &/OR LOCAL EXHAUST WITH PROPER FILTRATION
EQUIPMENT TO CONTROL AIRBORNE LEVELS BELOW EXPOSURE LIMITS.
Other Protective Equipment:PROT CLTHG IMPERVIOUS TO THIS MATL. BOOTS,
APRON/FULL BODY SUIT WILL DEPEND ON OPERATION.
Work Hygienic Practices:REMOVE CONTAMD CLTHG, WASH SKIN AREA W/SOAP &
WATER.
Supplemental Safety and Health
EXPLO HAZ: HEAT MAY UNDERGO DECOMP REL TOX VAPS SUCH AS HYDROCHLORIC
ACID, CARBON DIOXIDE, CARBON MONOXIDE, NITROGEN OXIDES, CHLORINE,
ORTHO-CHLOROANILINE & NITROSO AMINES. MATL TO AVOID: CHEM SUCH AS
LIQ AMMONIA. EFTS OF OVEREXP: IF HEATED, EXCESS CONC ARE ATTAINABLE
THAT COULD BE HAZ ON SINGLE EXPOS. (ING 2)
================== Physical/Chemical Properties ==================
Vapor Pres:NEGLIGIBLE
Spec Gravity:1.23@70F
Solubility in Water:MISCIBLE
Appearance and Odor:AMBER LIQUID, SLIGHT ODOR
Percent Volatiles by Volume:NEGLIG
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & BASES.OXIDIZERS & REDUCING AGENTS. REACTIVE METALS SUCH
AS ALUMINUM/MAGNESIUM & OTHER REACTIVE(SUPP DATA)
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CHLORINE, ORTHO-CHLOROANILINE,
HYDROCHLORIC ACID, CARBON DIOXIDE, CARBON MONOXIDE, NITROGEN OXIDES
& NITROSO AMINES.
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW ALL FEDERAL, STATE AND LOCAL REGULATIONS.
ALTHOUGH THIS PROD IS NOT SPECIFICALLY LISTED AS A HAZ WASTE IT
DOES CNTN 4,4'-METHYLENEBIS-2-CHLOROANILINE WHICH IS LISTED AS A
HAZ WASTE. EMPTY DRUMS MEETING RCRA DEFINITION OF EMPTY ARE (ING
9)
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:XP1 BLEACH-FIX, PART B
Kit Part:Y
CAGE:64145
CAGE:64145
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM METABISULFITE
CAS:7681-57-4
RTECS #:UX8225000
Fraction by Wt: 1-5%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3; 9192
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 40-45%
Ingred Name:AMMONIUM THIOSULFATE
CAS:7783-18-8
RTECS #:XN6465000
Fraction by Wt: 40-50%
Ingred Name:SODIUM SULFITE
CAS:7757-83-7
RTECS #:WE2150000
Fraction by Wt: 1-5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT MAY CAUSE EYE, SKIN & G/I
TRACT IRRITATION. IT IS CONSIDERED A LOW HAZARD FOR NORMAL
INDUSTRIAL HANDLING AND INHALATION IS AN UNLIKELY EXPOSURE.
Explanation of Carcinogenicity:THIS PRODUCT CONTAINS NO INGREDIENT
IDENTIFIED BY NTP,IARC, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYE:CAUSES IRRITATION SKIN:MAY CAUSE
IRRITATION. INHALED:UNLIKELY EXPOSURE,MAY CAUSE IRRITATION IF MIST
IS INHALED. INGESTED:MAY BE HARMFUL IF SWALLOWED. HMIS:MAY CAUSE
G/I IRRITATION,NAUSEA,VOMITIN G.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH WITH WATER 15 MIN.SKIN:REMOVE CONTAMINATED
CLOTHING AND LAUNDER BEFORE REUSE. WASH SKIN WITH SOAP AND WATER.
INHALED: REMOVE TO FRESH AIR. INGESTED:IF CONSCIOUS,GIVE 1-2
GLASSES OF WATE R AND IMMEDIATELY INDUCE VOMITING. (NOTHING BY
MOUTH IF UNCONSCIOUS.) GET IMMEDIATE MEDICAL CARE. IF ANY
IRRITATION PERSISTS OR IS SEVERE, GET MEDICAL CARE.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:USE MEDIA APPROPRIATE FOR SOURCE OF FIRE.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER AS LIQUID OR ADSORB WITH
CLOTH,PAPER,OTHER INERT MATERIAL.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY,WELL VENTILATED
AREA. KEEP TIGHTLY CLOSED WHEN NOT IN USE. KEEP AWAY FROM STRONG
ACIDS AND STRONG BASES.
Other Precautions:READ LABEL THEN FOLLOW INSTRUCTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. USE NIOSH/MSHA APPROVED
RESPIRATOR IF PEL/TLV IS EXCEEDED OR IF DISCOMFORT IS EXPERIENCED.
Ventilation:NORMAL ROOM VENTILATION SUPPLEMENTED BY LOCAL EXHAUST,
ESPECIALLY WHEN MIXING.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER. USE APRON
AND FACE SHIELD WHEN MIXING LIQUIDS OR IF SPLASHING IS LIKELY.
Work Hygienic Practices:USE GOOD CHEMICAL HYGIENE PRACTICE. AVOID
UNNECESSARY CONTACT.
Supplemental Safety and Health
ILFORD PRODUCES KITS CONTAINING DEVELOPER & BLEACH-FIXER. STOCK
NUMBERS: MG1516000 TO MAKE 2.5 L, MG1517000 TO MAKE 10 L, MG9012001
TO MAKE 2 L, AND MG9012002 TO MAKE 15 L. SEE NSN 6750-00-D00-2566
F OR MSDS OF BLEACH-FIX. COD = 180 GM OXYGEN/L PART B. ALSO SEE
ADD.DATA.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:<32F,<0C
Vapor Pres:AS WATER
Vapor Density:AS WATER
Spec Gravity:1.32
pH:8
Evaporation Rate & Reference:AS WATER
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID, NO ODOR
Percent Volatiles by Volume:30
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, STRONG BASES
Stability Condition to Avoid:NO INFORMATION GIVEN BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON
MONOXIDE,AMMONIA
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W FEDERAL,STATE,LOCAL REGULATIONS.
MFR SUGGESTS FLUSH TO SEWER IF PERMITTED.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:EPSYN ELASTOMER,7506
Resp. Party Other MSDS Num.:CR 2278 (R 9/90)
Preparer's Name:ENVIRONMENTAL & SAFETY SV
CAGE:TO546
CAGE:TO546
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE, PROPYLENE, ETHYLIDENE NORBORNENE, TERPOLYMER
RUBBER (EPDM), (CAS NAME: BICYCLO(2,2,1-)HEPT-2-ENE, 5-ETHYLIDENE-,
POLYMER WITH ETHENE AND 1-PROPENE)
CAS:25038-36-2
= Wt:99.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NO ACUTE OR CHRONIC HAZARDS OR EFFECTS
ARE KNOWN. EYE CONTACT: NOT A PROBABLE ROUTE OF EXPOSURE.
PARTICULATES MAY SCRATCH EYE SURFACE OR CAUSE IRRITATION. SKIN
CONTACT: A SINGLE PROLONGED EXPOSURE IS NOT LIKELY TO RESULT IN
MATERIAL BEING ABSORBED THROUGH THE SKIN IN HARMFUL AMOUNTS.
REPEATED PROLONGED EXPOSURE MAY CAUSE MILD SKIN IRRITATION IN SOME
INDIVIDUALS. EXPOSURE TO HOT MATERIALS MAY CAUSE THERMAL BURNS.
INGESTION: NOT A PROBABLE ROUTE OF EXPOSURE. INHALATION: NOT A
PROBABLE ROUTE OF EXPOSURE UNDER CONDITIONS OF NORMAL USE. HOT
FUMES/VAPORS WHICH MAY FORM DURING PROCESSING CAN CAUSE IR RITATION
TO THE UPPER RESPIRATORY TRACT.
Explanation of Carcinogenicity:CARCINOGENICITY: NONE REPORTED
Effects of Overexposure:SEE HEALTH HAZARDS .
Medical Cond Aggravated by Exposure:SOME INDIVIDUALS WITH SPECIFIC
SENSITIVITIES MAY EXIBIT EYE, NOSE, THROAT OR THERMAL IRRITATION
WITH PROLONGED EXPOSURE TO PROCESSING FUMES OR VAPORS.
======================= First Aid Measures =======================
First Aid:EYE CONTACT: REMOVE AS FOR ANY FOREIGN OBJECT. FLUSH WITH
CLEAN WATER FOR 15 MINUTES. OBTAIN MEDICAL ATTENTION IF IRRITATION
PERSISTS. SKIN CONTACT: WASH WITH SOAP AND WATER. IF THERMAL
IRRITATION, F LUSH AFFECTED AREA WITH COLD WATER TO DISSIPATE HEAT,
THEN COVER WITH CLEAN COTTON SHEETING OR GAUZE AND GET PROMPT
MEDICAL ATTENTION.INHALATION: IF FUMES/VAPORS ARE INHALED, MOVE
TO FRESH AIR, AID BREATHING IF NECESSARY. OBTAIN MEDICAL ATTENTION
IF IRRITATION PERSISTS. INGESTION: UNLIKELY TO OCCUR.
===================== Fire Fighting Measures =====================
Flash Point:>300.C, 572.F
Autoignition Temp:=350.C, 662.F
Autoignition Temp Text:- 380C
Extinguishing Media:ALL FIRE EXTINGUISHING MEDIA PERMITTED - FOAM OR
WATER FOG RECOMMENDED
Fire Fighting Procedures:DURING EMERGENCY CONDITIONS, EXPOSURE TO
THERMAL DECOMPOSITION PRODUCTS MAY CAUSE A HEALTH HAZARD. USE OF
NIOSH APPROVED SELF CONTAINED BREATHING APPARATUS IS RECOMMENDED.
Unusual Fire/Explosion Hazard:NOT COMBUSTIBLE, BUT THE PRODUCT WILL
BURN IF IGNITED. IGNITION TEMPERATURE: ABOVE 200C (392F).
SENSITIVITY TO IMPACT/SHOCH: N/A. SENSITIVITY TO STATIC DISCHARGE:
N/A.
================== Accidental Release Measures ==================
Spill Release Procedures:REPACKAGE UNCONTAMINATED RUBBER. REUSE OR
DISPOSE OF (SEE DISPOSAL INFORMATION) IF CONTAMINATED.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 35C (95F) IN DRY AREA AND
IN THE ABSENCE OF DIRECT, NATURAL, OR ARTIFICIAL LIGHT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED AT AMBIENT TEMPERATURES.
IF PROCESSING IN AREA WHERE VENTILATION IS INADEQUATE, WEAR A NIOSH
APPROVED ORGANIC VAPOR RESPIRATOR WITH MECHANICAL FILTRATION.
Ventilation:LOCAL EXHAUST VENTILATION IS RECOMMENDED DURING ALL HOT
PROCESSING OPERATIONS.
Other Protective Equipment:WEAR CLOTHING APPROPRIATE TO PREVENT SKIN
CONTACT. WHERE CONTACT MAY OCCUR WITH HOT MATERIAL, WEAR ARM
PROTECTION AND A FACE SHIELD. EYEWASH & DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA .
Work Hygienic Practices:AVOID SKIN AND EYE CONTACT, PRACTICE GOOD
PERSONAL HYGIENE. AVOID INHALATION OF FUMES/VAPORS FROM HOT
RUBBERS, COMPOUNDS AND VULCANIZATES.
Supplemental Safety and Health
NFPA FIRE HAZARDS IDENTIFICATION SYSTEMS: HEALTH = 0, FIRES = 1,
REACTIVITY = 0, SPECIFIC = 0. ODOR THRESHOLD: NOT ESTABLISHED.
COEFFICIENT IN WATER/OIL DISTRIBUTION: NOT ESTABLISHED.
================== Physical/Chemical Properties ==================
Spec Gravity:0.86 - 0.88
Solubility in Water:INSOLUABLE (AT 20C)
Appearance and Odor:WHITE TO AMBER SOLID, BALES WITH SLIGHT ODOR
Percent Volatiles by Volume:0.75-1.0(WT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:PRODUCT IS STABLE AT AMBIENT TEMPERATURE
AND PRESSURE. HIGH TEMPERATURES, 300-350C (572-662F) WILL CAUSE
THERMAL DECOMPOSITION; IGNITION SOURCE.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
VARIOUS HYDROCARBONS, AND PRODUCTS FROM INCOMPLETE COMBUSTION.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:REPRODUCTIVE EFFECTS: NONE REPORTED.
TERATOGENICITY: NONE REPORTED. MUTAGENICITY: NONE REPORTED.
==================== Disposal Considerations ====================
Waste Disposal Methods:REUSE IF POSSIBLE. DISPOSE IN ACCORDANCE WITH
LOCAL, STATE, AND FEDERAL REGULATIONS AND APPLICABLE ENVIRONMENTAL
REGULATIONS. MATERIALS AS SUPPLIED ARE NOT CHARACTERIZED AS
HAZARDOUS UNDER RCRA.
=================== MSDS Transport Information ===================
Transport Information:DOT: UNITED STATES: DESIGNATION AND LABELING NOT
APPLICABLE AS PRODUCT IS NOT DEFINED OR DESIGNATED AS A HAZARDOUS
MATERIAL BY U.S. DEPARTMENT OF TRANSPORTATION UNDER TITLE 49 OF
CFR. CANADA: THIS PR ODUCT IS NOT REGULATED UNDER CANMADA'S
TRANSPORTATION OF DANGEROUS GOODS REGULATIONS.
===================== Regulatory Information =====================
SARA Title III Information:SECTION 302/304 EXTREMELY HAZARDOUS
SUBSTANCES - NONE.SECTION 311 HAZARDOUS SUBSTANCES - NOT
APPLICABLE. SECTION 313: THIS PRODUCT IS NOT SUBJECT TO REPORTING
REQUIREMENTS (SEE 40 CFR 372).
Federal Regulatory Information:OSHA: THIS PRODUCT IS NOT HAZARDOUS
UNDER HAZARD COMMUNICATION STANDARD 29 CFR PART 1910.1200.TSCA:
COMPONENTS OF THIS PRODUCT ARE LISTED UNDER TSCA CHEMICAL SUBSTANCE
INVENTORY.FDA: GRADES 40A, 4 506, 5206, 5508, 70A, 7506 ARE IN
COMPLIANCE WITH 21 CFR 177.2600, 'RUBBER ARTICLES INTENDED FOR
REPEATED USE'. WHMIS: THIS PRODUCT IS NOT CONSIDERED A CONTROLLED
PRODUCT UNDER CANADA'S WORKPLACE HAZ ARDOUS MATERIAL INFORMATION
SYSTEM. CEPA: COMPONENTS OF THIS PRODUCT ARE INCLUDED IN CANADA'S
DSL. EEC: THIS PRODUCT IS NOT CONSIDERED HAZARDOUS BY THE
EUROPEAN ECONOMIC COMMUNITY.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:NICKEL-CADMIUM SEALED CELL BATTERY
Preparer's Name:WILLIAM O. ??
CAGE:09052
CAGE:67237
CAGE:09052
============= Composition/Information on Ingredients =============
Ingred Name:CADMIUM (SARA III)
CAS:7440-43-9
RTECS #:EU9800000
Fraction by Wt: 8-20%
Other REC Limits:NONE SPECIFIED
OSHA PEL:SEE 1910.1027
ACGIH TLV:0.01 MG/M3 DUST;9394
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 15-35%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE:CADMIUM AND ITS DUSTS, FUMES OR
COMPOUNDS MAY CAUSE RESPIRATORY IRRITATION IF INHALED; G/I
DISTRESS, NAUSEA, VOMITING, DIARRHEA. NICKEL MAY SENSITIZE CONTACT
DERMATITIS AND IF INGESTED CAUSE AB DOMINAL CRAMPS. CHRONIC:LUNG
INJURY, KIDNEY DISFUNCTION, BONE LESIONS.
Explanation of Carcinogenicity:CADMIUM AND NICKEL AND THEIR COMPOUNDS
ARE LISTED AS CARCINOGENS BY NTP & IARC. SEE INDIVIDUAL REPORTS FOR
DETAILS.
Effects of Overexposure:IRRITATION OF NOSE AND THROAT, SWEATING,
CHILLS, SHORTNESS OF BREATH, WEAKNESS, LOCAL DERMATITIS, NAUSEA,
COUGHING, CHEST PAINS.
Medical Cond Aggravated by Exposure:RESPIRATORY DISORDERS, PROSTATE
DISORDERS, LIVER
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SEE PHYSICIAN.
EYES/SKIN:FLUSH WITH WATER FOR 15 MINUTES. SEE PHYSICIAN IF
SYMPTOMS DEVELOP. INGESTION: INDUCE VOMITING IF CONSCIOUS, SEE A
PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL, CO2, WATER
Fire Fighting Procedures:USE NIOSHMSHA SELF-CONTAINED BREATHING
APPARATUS AND FULL PROTECTIVE CLOTHING IF INVOLVED IN A FIRE.
Unusual Fire/Explosion Hazard:"NOT APPLICABLE"
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL. COLLECT SPILL AND PLACE IN
PLASTIC LINED CONTAINER. HEPA VACUMING OF DUST IS PREFFERED. FLUSH
SPILL AREA WITH WATER.
Neutralizing Agent:NO INFORMATION GIVEN BY MFR ON THE MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:WEAR NIOSH/MSHA APPROVED DUST MASKS OR
Other Precautions:KEEP CONTAINER CLOSED, AVOID CONTACR WITH CLOTHING
AND AVOID GENERATING DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED FOR DUSTS.
Ventilation:USE LOCAL EXHAUST AND MECHANICAL (GENERAL) VENTILATION.
MAINTAIN OSHA PEL.
Other Protective Equipment:DO NOT WEAR CONTAMINATED CLOTHING HOME.
SHOWER AND CHANGE OR WEAR COVERALLS.
Work Hygienic Practices:KEEP FOOD AND TOBACCO AWAY FROM WORK AREA.
Supplemental Safety and Health
OBSOLETE MSDS RECEIVED FROM NAVY (FOCAL POINT N). NAVY IDENTIFIED NSN.
A MORE CURRENT ONE FROM HMIS WAS SUBSTITUTED. MSDS WAS FOR A
SEALED BATTERY.
================== Physical/Chemical Properties ==================
HCC:Z5
NRC/State Lic Num:NONE
Spec Gravity:1.6
Solubility in Water:LEFT BLANK BY MFR
Appearance and Odor:LEFT BLANK BY MFR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:GENERAL STORAGE CONDITIONS FOR HAZARDOUS
MATERIALS ARE ACCEPTABLE.
Hazardous Decomposition Products:METAL OXIDE FUMES MAY BE EVOLVED AT
TEMPERATURES ABOVE MELTING POINT.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. IF DISCARDED TREAT AS HAZARDOUS WASTE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SELAMINE 180
CAGE:60358
CAGE:60358
============= Composition/Information on Ingredients =============
Ingred Name:CYCLOHEXYLAMINE (SARA III)
CAS:108-91-8
RTECS #:GX0700000
Fraction by Wt: 70-90%
Other REC Limits:N/K
OSHA PEL:10 PPM
ACGIH TLV:10 PPM; 9192
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS AND SYMPTOMS OF
OVEREXPOSURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:CORR,IMMED HIGHLY PAINFUL IRRIT,INTENSE
WATERING,DAMAGE TO MUC MEMB.SKIN:CORR,ITCHING,TINGLING,PAINFUL
BURNING/ULCERATION.INGEST:CORR,IMMED BURNING SENSATION IN
MOUTH,THROAT & STOMACH,NAUSEA,VOMI T,RAPID BRTHG,SHOCK.INHAL:MILD
TO SEVERE IRRIT OF NOSE,THROAT & EYES.DIFFICULTY IN
BREATHING.COUGHING.
Medical Cond Aggravated by Exposure:N/K
======================= First Aid Measures =======================
First Aid:EYES:W/ LIDS OPEN FLUSH IMMED W/ PLENTY OF H*2O FOR AT LEAST
15 MIN.GET MD.SKIN:FLUSH IMMED W/ PLENTY OF H*2O FOR AT LEAST 15
MIN.SHOWER W/ SOAP & H*2O.WASH CONTAM CLTHG BEFORE USE.GET MD IF
BURNS/COM PLICATIONS ARISE.INGEST:RINSE MOUTH W/ COLD H*2O.GIVE
COLD H*2O,MILK W/ RAW EGGS,FRUIT JUICE,VINEGAR-H*2O (1:2).IF IN
SHOCK,LAY DOWN,WRAP UP.GET MD.INHAL:MOVE TO FRESH AIR.IF EFFECTS
OCCUR,GET MD.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:115F,46.11C
Extinguishing Media:FOAM,CARBON DIOXIDE,DRY CHEMICAL OR WATER.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .DILUTION OF BURNING LIQUID WITH LARGE VOLUMES
OF WATER WILL REDUCE THE INTENSITY OF THE FLAME.
Unusual Fire/Explosion Hazard:DO NOT EXPOSE TO HEAT OR FLAMES.CAN REACT
VIGOROUSLY WITH OXIDIZING MATERIALS.THERMAL DECOMPOSITION MAY
PRODUCE NITROGEN OXIDES,CARBON MONOXIDE,CARBON DIOXIDE.
================== Accidental Release Measures ==================
Spill Release Procedures:NO SMOKING OR FLARES.KEEP PEOPLE AWAY.KEEP
UPWIND.SHUT OFF LEAK IF WITHOUT RISK.IF NECESSARY TO ENTER SPILL
AREA,WEAR APPROPRIATE PROTECTIVE EQUIPMENT.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT GET IN EYES,ON SKIN OR
AT AMBIENT TEMPERATURE.STABLE FOR ONE YEAR.
Other Precautions:DO NOT TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ATMOSPHERIC LEVELS SHOULD BE MAINTAINED BELOW
THE EXPOSURE GUIDELINE.NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT FOR MOST
CONDITIONS.LOCAL EXHAUST IS RECOMMENDED.
Other Protective Equipment:EYE WASH AND SAFETY SHOWERS SHOULD BE
READILY AVAILABLE.CLEAN LONG-SLEEVED BODY-COVERING CLOTHING.RUBBER
APRON.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.AVOID
CONTAMINATION OF FOOD.
Supplemental Safety and Health
N/K
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Spec Gravity:0.89 (WATER=1)
pH:11-13
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR TO LIGHT STRAW LIQUID.AMINE-LIKE ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS AND OXIDIZING MATERIAL.
Stability Condition to Avoid:CONTAMINATION WITH ACIDS OR OXIDIZERS.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY PRODUCE
NITROGEN OXIDES,CARBON MONOXIDE,AND/OR CARBON DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .FLUSH AREA WITH LARGE AMOUNTS
OF WATER.LARGE RUNOFF TO SEWER MAY CREATE HAZARD.NOTIFY
AUTHORITIES.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:RICOH NT-40 TONER
Preparer's Name:R.L. SEVIGNY
CAGE:82784
CAGE:82784
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE ACRYLATE COPOLYMER (SYTRENE/ACRYLATE POLYMER)
CAS:25213-39-2
Fraction by Wt: 80-90%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 10-15%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:PIGMENT, BLACK
CAS:84179-66-8
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NO KNOWN HEALTH HAZARD WHEN USED AS
INTENDED IN A COPY MACHINE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:IRRITATION OF EYES AND RESPIRATORY TRACT MAY
OCCUR IN HEAVY DUST CONDITIONS
Medical Cond Aggravated by Exposure:ONE KNOWN.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM EXPOSURE. SKIN: WASH WITH SOAP. EYES:
FLUSH EYES WITH WATER FOR AT LEAST 15 MIN. INGEST: DRINK WATER IF
INGESTED.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL, CO*2.
Fire Fighting Procedures:AVOID INHALATION OF SMOKE. WEAR NIOSH/MSHA
APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MATERIAL CAN FORM EXPLOSIVE MIXTURES WHEN
SUSPENDED IN AIR. ALL IGNITION SOURCES SHOULD BE AVOIDED.
================== Accidental Release Measures ==================
Spill Release Procedures:ACUUM OR SWEEP UP AS WITH ANY NON-TOXIC
POWDER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE NEXT TO STRONG OXIDIZERS.
Other Precautions:AVOID EXCESSIVE EXPOSURE TO HEAT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ONE REQUIRED WHEN PRODUCT IS USED AS INTENDED.
NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN
.
Ventilation:LOCAL EXHAUST/MECHANICAL (GENERAL): NORMAL OFFICE
CONDITIONS.
Other Protective Equipment:NONE REQUIRED WHEN USED AS INTENDED.
Work Hygienic Practices:AVOID BREATHING DUST IF SAMPLE IS SPILLED.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:160F,71C
Spec Gravity:1 (H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK POWDER, FAINT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE WITH COMMON MATERIALS WITH WHICH THE PRODUCT MAY REASONABLY COME
INTO CONTACT.
Stability Condition to Avoid:AVOID OPEN FLAME.
Hazardous Decomposition Products:TOXIC DECOMPOSITION PRODUCTS FORMED ON
COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE ACCORDING TO FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:OE-50 (MC 1094)
CAGE:58563
CAGE:58563
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM BASED LUBRICANTS(OIL)
Fraction by Wt: 100%
===================== Hazards Identification =====================
Effects of Overexposure:NONE NOTED BY MFR. LOW TOXICITY & LOW HAZARD TO
HEALTH.
======================= First Aid Measures =======================
First Aid:SKIN:WASH WITH SOAP AND WATER. EYES: FLUSH WITH WATER.
INHALED: REMOVE TO FRESH AIR. REMOVE CONTAMINATED CLOTHING.
===================== Fire Fighting Measures =====================
Flash Point:230C(446F)-(OC
Extinguishing Media:CO*2, FOAM, DRY CHEM & H*2O FOG.
Fire Fighting Procedures:USE MESA/NIOSH APPRVD SCBA;USE H*2O SPRAY TO
COOL CONTNRS.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE & CONTAIN SPILL W/INERT
MATERIAL(SAND,EARTH,FULLERS EARTH ETC.) TRANSFER LIQ TO DRUMS OR
OTHER CONTAINERS FOR RECOVERY/DISPOSAL.AREA MAY BE SLIPPERY CARE
SHOULD BE TAKEN TO AVOID FALLS."PREVENT M ATL FROM GETTING INTO
SEWERS/OPEN BODIES OF H*2O".
======================Handling and Storage ======================
Handling and Storage Precautions:THESE LUBRICANTS BECOME VERY VISCOUS
WHEN STORED AT LOW TEMPERATURES.THEY CONGEAL AT TEMPERATURES FROM
-12 TO -32C.
============= Exposure Controls/Personal Protection =============
Ventilation:NORMAL ROOM VENTILATION.
Other Protective Equipment:EYEWASH FACILITY
Supplemental Safety and Health
MFR SPECIFD 6/22/84,PROD MFD IAW MIL-L-2104C,AMD 1;SINCE OE-50 NOT
INCLUDED IN MIL-L-2104D,THIS ITEM NOT AVAILABLE UNDER CONTRACT;SEE
P/N IND A FOR DATA ON OE-50(MC 1109); MSDS UNDATED.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:>600F
Vapor Pres:<1
Vapor Density:<1
Spec Gravity:<1.0
Evaporation Rate & Reference:<1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DARK AMBER OIL,NO ODOR
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, IGNITION SOURCES
Hazardous Decomposition Products:ONLY WHEN BURNING,GIVES CARBON
MONOXIDE & CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:190 8748 ACCUMAX 2000 RA DEVELOPER & REPLENISHER,WORK SOLN
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 90-95%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM SULFITE
CAS:10117-38-1
RTECS #:WT3530000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:HYDROQUINONE (SARA 302/313) (CERCLA)
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9596
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SODIUM CARBONATE
CAS:497-19-8
RTECS #:VZ4050000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM BROMIDE
CAS:7647-15-6
RTECS #:VZ3150000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:EXPECTED TO BE LOW HAZ FOR
RECOMMENDED HNDLG.EYE:CAUSES IRRIT.SKIN:CAUSES IRRIT.MAY CAUSE
ALLERGIC SKIN RX.INGEST:EXPECTED TO BE LOW INGEST HAZARD.
Explanation of Carcinogenicity:PER MSDS:CARCINOGENICITY
CLASSIFICATION:IARC/ACGIH/NTP/OSHA:NONE.
Effects of Overexposure:EYE/SKIN IRRIT. ALLERGIC SKIN REACTION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:IF SYMPTOMATIC MOVE TO FRESH AIR.GET MED ATTN IF
SYMPTOMS PERSIST. EYES:IMMED FLUSH W/PLENTY OF WATER FOR @LEAST
15MNS.GET MED ATTN. SKIN:IMMED REMOVE CONTAMIN CLOTH/SHOES.WASH
W/SOAP/PLENTY OF WATER.GET MED ATTN. INGEST:DRINK 1-2 GLASSES OF
WATER.SEEK MED ATTN.NEVER GIVE ANYTHING BY MOUTH IF UNCONSC.
===================== Fire Fighting Measures =====================
Flash Point:NONE,NON-COMBUST
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE. NON-COMBUSTIBLE LIQUID.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER W/LG AMTS OF WATER.OTHERWISE
ABSORB W/VERMICULITE OR OTHER INERT MATL THEN PLACE IN CONTAINER
FOR CHEM WASTE.CLEAN SURFACE THOROUGHLY TO REMOVE RESIDUAL
CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID EYE/SKIN/CLOTH CONTACT.USE
W/ADEQUA VENTI.ROUTINE USE OF NONALKALINE(ACID)TYP HNDCLNR/REG
Other Precautions:KEEP CNTNR CLSD.MATL MOD ALKALINE AQU
SOLN.PROPERTIES:MOD BIOCHEM OXY DEMAND,MAY CASUE OXY DEPLETION IN
AQU SYS;HI POT TO AFFECT SOME AQU ORG;MOD POT TO AFFECT 2ND WASTE
TREAT MICROBIAL METABOLISM/GER MINATION/ (SUPPLEMENTAL)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES/HR)
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:EYEBATH, WASHING FACILITIES, SAFETY SHOWER.
PROTECTIVE CLOTHING APPROPRIATE FOR RISK OF EXPOSURE.
Work Hygienic Practices:WASH CONTAMIN CLOTH BEF REUSE;DESTROY/CLEAN
WELL CONTAMIN SHOES.WASH THOROUGHLY AFT HNDLG.
Supplemental Safety and Health
OTHER PRECAUT:GERM &/OR EARLY GROWTH OF SOME PLANTS;LOW POT TO PERSIST
IN ENVIRO/TO BIOCONCEN.AFT DIL W/LG AMT OF WATER/2ND WASTE TREAT
MATL NOT EXPECTED TO CAUSE ADVERSE ENVIRO EFFECTS. PNIND:A FOR C
ONCNETRATE;TO MAKE 25 GALLONS.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:NP
Decomp Temp:Decomp Text:NP
Vapor Pres:18MM
Vapor Density:0.6
Spec Gravity:1.05
pH:10.5
Evaporation Rate & Reference:NP
Solubility in Water:COMPLETE.
Appearance and Odor:LIQUID, COLORLESS, ODORLESS.
Percent Volatiles by Volume:90-95
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE W/COMMON MATERIALS & CONTAMINANTS W/WHICH MATERIAL MAY REASONABLY
COME INTO CONTACT.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOIXDE,
SULFUR DIOXIDE. HAZ COMBUST PROD:NONE (NON-COMBUSTIBLE).
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE/TREATMENT/DISPOSAL MAY BE SUBJECT TO
NATIONAL/STATE/LOCAL LAWS.FLUSH TO SEWER W/LG AMTS OF WATER.CHEM(S)
SUBJ TO SEC 313 TITLE III SARA/40CFR372:HYDROQUINONE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:317 STAINLESS STEEL ALLOYS
CAGE:56406
Contract Num:SP0490-96-D-41690
CAGE:56406
============= Composition/Information on Ingredients =============
Ingred Name:NICKEL
CAS:7440-02-0
RTECS #:QR5950000
= Wt:14.
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
= Wt:4.
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:CHROMIUM
CAS:7440-47-3
RTECS #:GB4200000
= Wt:21.
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:MANGANESE
CAS:7439-96-5
RTECS #:OO9275000
= Wt:2.5
OSHA PEL:C5 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: BALANCE
OSHA PEL:NONE
ACGIH TLV:NONE
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:ACUTE: SHORT TERM EXPOSURE TO WELDING
FUMES, GASES OR DUST MAY RESULT IN DISCOMFORT SUCH AS DIZZINESS,
NAUSEA, FEVER, DRYNESS AND OR IRRITATION OF NOSE, THROAT, EYES.
SKIN SENSITIVITY MAY ALSO BE NOTE D. ACUTE EXPOSURE CAN RESULT IN
THE SAME SYMPTOMS EXCEPT TO A GREATER DEGREE AS WELL AS WATERY
EYES, HEADACHE, BRATHING DIFFICULTY, FREQUENT COUGHING AND/OR CHEST
PAINS. SOME GASES MAY CAUSE PULMONARY EDEMA, ASPHYXIATION AND
EXCESSIVE EXPOSURE CAN BE FATAL. CHRONIC: MAY RESULT IN
NEUROLOGICAL DAMAGE, LUNG FIBROSIS, PNEUMONICOCIS AND OTHER LUNG
DISORDERS.
Explanation of Carcinogenicity:NICKEL AND CHROMIUM ARE CONSIDERED
POSSIBLE CARCINOGENS UNDER OSHA (29CFR 1910-1200). "SEE TOXICOLOGY"
Effects of Overexposure:***THIS PRODUCT POSES NO HEALTH HAZARD AS
SHIPPED*** BUT MAY POSE A HEALTH HAZARD DURING USE. ELECTRIC ARC
WELDING RAYS CAN INJURE EYES & BURN SKIN. DUST, FUMES AND GASES CAN
BE DANGEROUS TO YOUR HEAL TH. LUNG DAMAGE MAY RESULT FROM
OVEREXPOSURE.
Medical Cond Aggravated by Exposure:SOME WORKERS MAY BE AFFECTED BY A
PREEXISTING CONDITION OR OTHER OCCUPATIONAL ILLNESS BECAUSE OF THE
WIDE VARIATION IN INDIVIDUAL SUSCEPTIBILITIES.
======================= First Aid Measures =======================
First Aid:IN CASE OF ELECTRICAL SHOCK, TURN OFF POWER PRIOR TO REMOVAL
FROM EXPOSURE AREA AND ADMINISTRATION OF FIRST AID. INHALATION:
REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT ADMINISTER OXYGEN.
IF NOT BR EATHING BEGIN ARTIFICIAL RESPIRATION. IF NO DETECTABLE
PULSE BEGIN EXTERNAL HEART MASSAGE. SKIN: WASH AFFECTED AREA WITH
SOAP AND WATER. EYES: FLUSH WITH LARGE AMOUNTS OF FRESH AIR FOR AT
LEAST 15 MIN UTES. INGESTION: SEEK MEDICAL ATTENTION. IN ALL CASES
SEEK MEDICAL ATTENTION FOR FIRST AID.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Unusual Fire/Explosion Hazard:NONFLAMMABLE, HOWEVER, ARCS, SPARKS AND
MOLTEN METAL CAN IGNITE FLAMMABLES AND COMBUSTIBLES OR CAUSE
EXPLOSIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP ANY GRINDING DUST OR WASTE RESIDUES
AND PLACE IN SUITABLE DEPARTMENT OF TRANSPORTATION APPROVED
CONTAINERS AND DISPOSE OF IN FULL COMPLIANCE WITH FEDERAL, STATE
AND LOCAL REGULATIONS. AVOID I NHALATION AND SKIN EXPOSURE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE WELD FUME RESPIRATOR OR AIR SUPPLIED
RESPIRATOR WHEN CUTTING, GRINDING OR WELDING IN A CONFINED SPACE OR
WHERE LOCAL EXHAUST OR GENERAL VENTILATION DOES NOT KEEP EXPOSURE
BELOW RECOMMENDED LIMITS. MONITOR THE AIR QUALITY INSIDE THE
WELDER'S HELMET, IF WORN, AND/OR THE WORKER'S BREATHING ZONE TO
DETERMINE IF A RESPIRATOR IS REQUIRED AND THE TYPE NEEDED.
Ventilation:USE ENOUGH VENTILATION TO KEEP DUST, FUMES AND GASES FROM
WORKER'S BREATHING ZONE AND GENERAL USE. KEEP EXPOSURE BELOW
LIMITS.
CUTTING, GRINDING OR WELDING. DO NOT EXPOSE SKIN TO RADIATION WHEN
HOT CUTTING OR WELDING. PROVIDE PROTECTIVE SCREENS TO SHIELD
OTHERS.
Work Hygienic Practices:DO NOT EXPOSE SKIN TO RADIATION WHEN NOT
CUTTING OR WELDING.
Supplemental Safety and Health
RESPIRATORY PROTECTION: USE ONLY NIOSH APPROVED RESPIRATORS. EYE
WHEN CUTTING, GRINDING OR WELDING. IN ADDITION, WHEN HOT CUTTING OR
WEL DING, WEAR WELDING HELMET OR FACE SHIELD WITH FILTER LENS.
SELECT WELDING LENS SHADE FROM AWS PUBLICATION F2.2.
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:COVERED WELDING ELECTRODES ARE SOLID WIRE WITH A
FLUX COATING.
================= Stability and Reactivity Data =================
Hazardous Decomposition Products:GASEOUS REACTION PRODUCTS MAY INCLUDE
CARBON MONOXIDE, OZONE AND NITROGEN OXIDES. CHLORINATED SOLVENTS
MAY BE DECOMPOSED INTO TOXIC GASES SUCH AS PHOSGENE.
=================== Toxicological Information===================
Toxicological Information:THE STUDIES FORMING THE BASIS FOR THIS
CLASSIFICATION WERE FROM OPERATIONS OTHER THAN WELDING OF CHROMIUM
OR NICKEL. THERE IS CONSIDERABLE CONTROVERSY ON THE EXTENT OF THE
RESPIRATORY CANCER PROBLEMS DUE TO NICKEL & CHROMIUM. IN ADDITION
A SMALL AMOUNT OF SILICA IS ALSO PRESENT & IT IS A PROBABLE
CARCINOGEN. NEVERTHELESS EXPOSURES MUST BE MAINTAINED BELOW THE
LEVELS SPECIFIED IN THE INGREDIENTS SE CTION. *THE LIMIT FOR
WELDING FUMES NOT OTHERWISE CLASSIFIED IS 5 MG/M3. SOME ELEMENTS OR
COMPONENTS WILL EXCEED THEIR PELS/TLVS BEFORE THE TOTAL FUMES
EXCEED 5 MG/M3.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN FULL COMPLIANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS
=================== MSDS Transport Information ===================
Transport Information:DOT CLASSIFICATION: FLAMMABLE GAS 2.1
===================== Regulatory Information =====================
SARA Title III Information:WELDING PRODUCTS LISTED IN THE INGREDIENTS
SECTION OF THIS MATERIAL SAFETY DATA SHEET CONTAIN TOXIC CHEMICALS
SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF TITLE III
OF THE SUPERFUND AMENDME NTS AND REAUTHORIZATION ACT OF 1986 AND
40CFR PART 372 OF THE FEDERAL REGISTER. REFER TO THE FOLLOWING
SOURCE FOR ADDITIONAL IMPORTANT INFORMATION: ANSI Z49.1 THE
AMERICAN WELDING SOCIETY. P.O. BOX 35 1040. MIAMI, FL 33135. DSHA
(29CFR 1910) U.S. DEPARTMENT OF LABOR. WASHINGTION, DC 20210.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TT-L-20A LACQUER AIR DRY FLAT LIGHT GRAY AEROSOL
CAGE:06341
CAGE:06341
============= Composition/Information on Ingredients =============
Ingred Name:ALKYD RESIN (PROPRIETARY INGREDIENT)
Fraction by Wt: 12.23%
Other REC Limits:NONE RECOMMENDED
Ingred Name:VM&P NAPHTHA (SARA 313) (VP = 5.4 @ 20C)
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 3.75%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:300 PPM/STEL 400
ACGIH TLV:300 PPM
Ingred Name:ISOBUTANOL (CERCLA) (VP = 8.8 @ 20C
CAS:78-83-1
RTECS #:NP9625000
Fraction by Wt: 1.89%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:50 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PM ACETATE (PMA) (VP = 3.7 @ 20C)
CAS:108-65-6
RTECS #:AI8925000
Fraction by Wt: 0.35%
Other REC Limits:NONE RECOMMENDED
Ingred Name:XYLENE (SARA 313) (CERCLA) (VP = 6.6 @ 20C)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 0.55%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM/STEL 150
ACGIH TLV:100 PPM/STEL 150
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ADDITIVE-GRINDING AGENT (PROPRIETARY INGREDIENT)
Fraction by Wt: 0.63%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 16.85%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:ETHYL ACETATE (CERCLA) (VP = 76 @ 20C)
CAS:141-78-6
RTECS #:AH5425000
Fraction by Wt: 8.26%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE (MEK) (SARA 313) (CERCLA) (VP = 70 @
20C)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 20.8%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM/STEL 300
ACGIH TLV:200 PPM/STEL 300
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:NITROCELLULOSE
CAS:9004-70-0
RTECS #:QW0970000
Fraction by Wt: 5.95%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHANOL (ET/AL) (VP = 53 @ 20C)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 2.42%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ingred Name:ISOPROPANOL (SARA 313) (VP = 37 @ 20C)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 0.13%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:400 PPM/STEL 500
ACGIH TLV:400 PPM/STEL 500
Ingred Name:N-BUTYL ACETATE (CERCLA) (VP = 14 @ 20C)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 17.58%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:150 PPM/STEL 200
ACGIH TLV:150 PPM/STEL 200
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:DIPHTHALATE DEHP (SARA 313) ORAL LD50 (RABBIT) 30.6 G/KG,
33.9 G/KG DERMAL LD50 (RABBIT) >20 ML/KG INHAL LC50 NA
CAS:117-81-7
RTECS #:TI0350000
Fraction by Wt: 2.40%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:CARBON BLACK PIGMENT
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 0.01%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:TOLUENE (SARA 313) (CERCLA) (VP = 24 @ 20C)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 0.02%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100/ PPM/ STEL 150
ACGIH TLV:100 PPM/STEL 150
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:YELLOW IRON OXIDE PIGMENT
CAS:51274-00-1
Fraction by Wt: 0.03%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:FUMED SILICA
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 6.53%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:ADDITIVE (TRADESECRET #06-027)
Fraction by Wt: 0.21%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: STINGING TEARING, REDNESS,
SWELLING & EYE DAMAGE. SKIN: REDNESS, BURNING, DRYING, CRACKING.
INHAL: HEADACHE, DROWSY, DIZZY, LOSS OF COORDINATION & FATIGUE.
Explanation of Carcinogenicity:DIPHTHALATE DEHP, LISTED BY MFR.
Medical Cond Aggravated by Exposure:ASTHMA & DERMATITIS.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/WATER FOR 20 MINUTES, LIFTING LIDS. SKIN: REMOVE
CLOTHES/SHOES. WASH W/MILD SOAP/WATER. INHAL: GET FRESH AIR. ARTIF
RESP/OXYGEN IF NEEDED. RESPIRTORY SYMPTOMS/OTHER SYMPTOMS OF
EXPOSURE DEVELOP. INGEST: GET MEDICAL ATTENTION.IN ALL CASES, GET
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:24.0F,-4.4C
Lower Limits:0.9
Upper Limits:19.0
Extinguishing Media:DRY CHEMICAL, CO2 OR UNIVERSAL TYPE FOAM.
Fire Fighting Procedures:RESPIRATORY PROTECTION & EQUIPMENT. STOP
LEAKS. REMOVE UNDAMAGED CONTAINERS. USE WATER SPRAY. DONT SPREAD
BURNING LIQ W/WATER. CONTAINER MAY EXPLODE.
Unusual Fire/Explosion Hazard:FLAMMABLE & MAY BE IGNITED BY IGNITS.
VAPORS >AIR & MAY TRAVEL TO IGNITS & ACCUMULATE IN LOW AREAS. MAY
CREATE VAPOR/EXPLOSION HAZ INDOORS/OUTDOOORS/SEWERS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITS & HOT METAL SURFACES. USE
PROTECTIVE EQUIPMENT. DIKE W/ABSORBENT. SCOOP, PUMP, ABSORB SPILL
INTO CONTAINER FOR DISPOSAL/REUSE. DRAIN, RINSE PROPERLY DISPOSE OF
EMPTY CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. STORE IN A
COOL, DRY, VENTED AREA. AWAY FROM IGNITS, DIRECT SUNLIGHT, HOT
METAL SURFACES. POST "NO SMOKING OR OPEN FLAME" SIGN.
Other Precautions:GROUND & BOND ALL EQUIPMENT WHEN TRANSFERRING.
EXPLOSION-PROOF EQUIPMENT REQUIRED. EMPTY CONTAINERS RETAIN RESIDUE
LIQUID/VAPORS & CAN BE DANGEROUS. DONT PRESSURIZE, WELD, CUT,
BRAZE, SOLDER, DRILL, G RIND, EXPOSE CONTAINERS TO HEAT/IGNITS
============= Exposure Controls/Personal Protection =============
Respiratory Protection:REQUIRED
Ventilation:EXHAUST SYSTEM, ELECTRICAL & MAYBE ADDITIONAL VENTILATION.
Other Protective Equipment:EYEWASH STATION, SAFETY SHOWER, & IMPERVIOUS
CLOTHING/SHOES.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:165 TO 723F
Vapor Density:>AIR
Spec Gravity:1.08
VOC Pounds/Gallon:435
Evaporation Rate & Reference:SLOWER THAN (BUAC)
Percent Volatiles by Volume:70.13
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, BASES, OXIDIZERS & SELECT AMINES.
Stability Condition to Avoid:SOURCES OF IGNITION.
Hazardous Decomposition Products:CO, CO2 & OTHER UNKNOWN HAZARDOUS
PRODUCTS ARE POSIBLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE W/FEDERAL, STATE, & LOCAL
REGULATIONS.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:N-1030 ADHESIVE
CAGE:81349
CAGE:81349
============= Composition/Information on Ingredients =============
Ingred Name:CATALYST
Fraction by Wt: 2%
Ingred Name:VEHICLE
Fraction by Wt: 17%
Ingred Name:SOLVENTS
Fraction by Wt: 72%
Ingred Name:ADDITIVES
Fraction by Wt: 9%
===================== Hazards Identification =====================
Effects of Overexposure:NARCOSSIS,STUPOR, DROWSINESS
======================= First Aid Measures =======================
First Aid:FRESH AIR AND/OR OXYGEN.OBTAIN MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:20 F TOC -7C
Lower Limits:1.2
Upper Limits:7.0
Extinguishing Media:CO*2,POWDER CHEMICALS, TRICHLOROETHANE
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS NIOSH
APPROVED.
Unusual Fire/Explosion Hazard:AVOID CONTACT WITH OXIDIZERS,OPEN
FLAME,SPARKS,HOT SURFACES.
================== Accidental Release Measures ==================
Spill Release Procedures:APPLY DRI-RITE OR SPEED-DRY ABSORBENT MATEIALS
TO SOAK UP LIQUID
======================Handling and Storage ======================
Handling and Storage Precautions:REASONABLE CAUTION TO AVOID CONTACT
WITH SKIN.STORE IN FLAMMABLE STORAGE AREA AT 60-90 F.
Other Precautions:KEEP OUT OF DIRECT SUNLIGHT AND IN SEALED CONTAINERS
============= Exposure Controls/Personal Protection =============
Ventilation:PREVENT VAPOR BUILD UP. MECHANICAL-CROSS VENTILATION
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:202 F 95 C
Vapor Pres:100
Vapor Density:3.06
Spec Gravity:0.875
Evaporation Rate & Reference:2.9
Appearance and Odor:OPAQUE CREAM COLOR,MOTHBALL,RUBBERY ODOR.
Percent Volatiles by Volume:81.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDES OF CARBON,SULFUR,NITROGEN,ZINC,MAGNESIUM,CHLORINE,FO
Stability Condition to Avoid:OXIDIZERS,OPEN FLAME,SPARKS, HOT SURFACES
Hazardous Decomposition Products:NO
==================== Disposal Considerations ====================
Waste Disposal Methods:SOLVENT WASTE STEEL DRUM.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ESW-M2C33-F,MOTORCRAFT FORD TYPE A ATF
CAGE:MO088
CAGE:MO088
CAGE:23040
CAGE:86511
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, SOLVENT-DEWAXED HEAVY
PARAFFINIC
CAS:64742-65-0
RTECS #:PY8038500
Fraction by Wt: >60%
Other REC Limits:2.5 MG/M3
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:PROPRIETARY INGREDIENT
Fraction by Wt: <40%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INGESTION:LOW TOXICITY. MAY
CAUSE VOMITING AND DIARRHEA.SMALL AMOUNT ASPIRATED INTO LUNGS WILL
CAUSE LUNG INJURY. INHALATION:INHALATION OF MIST/VAPORS/FUMES MAY
CAUSE RESPIRATORY TRACT IRRITATIO N. EYE:IRRITATION. SKIN:REPEATED
CONTACT MAY CAUSE IRRITATION. CHRONIC:IRRITATION/DERMATITIS, AND
CARDIAC SENSITIZATION.
Explanation of Carcinogenicity:THE COMPONENTS OF THIS PRODUCT HAVE NOT
SHOWN ANY EVIDENCE OF BEING CARCINOGENIC.
Effects of Overexposure:SKIN, EYE AND RESPIRATORY IRRITATION., VOMITING
AND DIARRHEA.
Medical Cond Aggravated by Exposure:PERSONS WITH A SKIN AND CARDIAC
DISORDERS SHOULD USE CAUTION WHEN HANDLING OR USING THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER.
GET MEDICAL ATTENTION IF IRRITATION PERSISTS. INHALATION:REMOVE TO
FRESH AIR & RESTORE BREATHING IF NECESSARY. GET MEDICAL ATTENTION.
EYE:I MMEDIATELY FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING
EYELIDS OPEN. GET MEDICAL ATTENTION. INGESTION:GET IMMEDIATE
MEDICAL ATTENTION. DO NOT INDUCE VOMITING. NOTHING BY MOUTH IF
UNCONSCIOUS.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:345F,174C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP FLOW. RECOVER BY VACUUMING. WIPE OR MOP
UP OR ABSORB WITH DIATOMACEOUS EARTH OR OTHER INERT MATERIAL. STORE
IN APPROPRIATE CONTAINER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID STORAGE NEAR OPEN FLAME OR OTHER
SOURCES OF IGNITION. EXCESSIVE MISTING MAY CAUSE SLIPPERY FLOORS.
PROPER FOOTWEAR REQUIRED.
Other Precautions:WASH HANDS WITH SOAP AND WATER BEFORE EATING,
DRINKING, OR SMOKING. DO NOT CREAT MIST AND AVOID INHALING MIST OR
VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:SUFFICIENT TO MAINTAIN ATMOSPHERE BELOW TLV LIMIT.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER. CHEMICALLY
RESISTANT BOOTS AND APRONS RECOMMENDED.
Work Hygienic Practices:DO NOT TAKE INTERNALLY. AVOID SKIN CONTACT.
WASH SKIN AFTER USING PRODUCT. DO NOT EAT, DRINK OR SMOKE IN WORK
AREA.
Supplemental Safety and Health
WASH OR TAKE SHOWER IF GENERAL CONTACT OCCURS. REMOVE OIL-SOAKED
CLOTHING AND LAUNDER BEFORE REUSE. DISCARD CONTAMINATED LEATHER
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:600F,316C
Spec Gravity:0.87
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:INDUSTRIAL EPOXY, 101-251B SEMI-GLOSS CATAL
CAGE:33200
CAGE:33200
============= Composition/Information on Ingredients =============
Ingred Name:EPOXY RESIN
Fraction by Wt: 43.4%
ACGIH TLV:300 PPM (MFR)
Ingred Name:2-ETHOXYETHYL ACETATE (CELLOSOLVE ACETATE) (EGEEA)
CAS:111-15-9
RTECS #:KK8225000
Fraction by Wt: 6.1%
OSHA PEL:S,100 PPM
ACGIH TLV:S, 5 PPM; 9192
Ingred Name:KETONES
Fraction by Wt: 4.1%
ACGIH TLV:100 PPM (MFR)
Ingred Name:AROMATIC NAPHTHA
CAS:64742-95-6
Fraction by Wt: 21.8%
ACGIH TLV:100 PPM (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: PROLONGED OR REPEATED EXPOSURE
MAY CAUSE IRRITATION. EYES: MAY CAUSE IRRITATION AND REDNESS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN: REMOVE EXCESS, WASH W/SOAP & COPIOUS WATER. EMULSIFY
W/VINEGAR (5% ACETIC ACID) IF NECESSARY. RINSE WITH WATER. EYES:
RINSE WITH WATER FOR AT LEAST 15 MINUTES. SEE MD IF IRRITATION OR
REDNESS PE RSISTS. INHAL: REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE
O*2/ARTF RESP). CALL MD IMMED . INGEST: GET MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:50.0F,10.0C
Lower Limits:1.3%
Upper Limits:7.55%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPORS MAY FORM EXPLOSIVE MIXTURES WITH
AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:BROADCAST VERMICULITE OR OTHER ABSORBANT
MATERIAL. SCOOP UP. SCRUB WITH 5% ACETIC ACID TO EMULSIFY. RINSE
WITH WATER.
Neutralizing Agent:SEE SPILL PROCEDURE.
======================Handling and Storage ======================
Handling and Storage Precautions:USE GOOD HOUSEKEEPING; DO NOT STORE IN
UNVENTILATED OR EXCESSIVELY HOT (OVER 120F) AREAS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST. GOOD GENERAL VENTILATION USUALLY ADEQUATE.
Other Protective Equipment:CLEAN, LONG LEG & LONG SLEEVE WORK CLOTHES.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:235F,113C
Vapor Pres:17
Vapor Density:3.2
Spec Gravity:1.231
Evaporation Rate & Reference:1.17 (NBUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TRANSLUSCENT AMBER LIQUID, ODOR CHARACTERISTIC OF
SOLVENTS USED.
Percent Volatiles by Volume:45.4
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
WATER OR OTHER HYDROXYL CONTAINING MATERIALS.
Stability Condition to Avoid:DO NOT MIX WATER WITH UNCURED MATERIAL.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE IN CLOSED CONTAINER & REMOVE TO APPROVED
LANDFILL OR BURN IN ADEQUATE INCINERATOR. DISPOSAL MUST BE I/A/W
FEDERAL, STATE, LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.