text
stringlengths 595
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:KODAK AQUA-IMAGE ADDITION PEN, 157 5174 - FINE
CAGE:EO271
CAGE:19139
CAGE:EO271
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ETHYL KETONE
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: <50%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYLCELLULOSE
CAS:9004-57-3
RTECS #:FJ5950500
Fraction by Wt: 25-30%
Other REC Limits:NONE RECOMMENDED
Ingred Name:EPOXY RESIN
Fraction by Wt: 10-15%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PIGMENTS
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV: MEK: 200 PPM TWA; 300 PPM STEL
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: EXPECTED TO BE LOW HAZARD
FOR RECOMMENDED HANDLING. EYES: CAUSES IRRITATION. SKIN: CAUSES
IRRITATION. INGESTION: EXPECTED TO BE A LOW INGESTION HAZARD.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION-IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES-IMMEDIATELY FLUSH WITH PLENTY
OF WATER FOR AT LEAST 15 MIN. GET MEDICAL ATTENTION.
SKIN-IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MIN.
GET MEDCIAL ATTENTION IF SYMPTOMS OCCUR. INGESTED-DRINK 1-2 GLASSES
OF WATER. SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:<100F,<38C
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE, BASED ON LIMITED QUANTITY OF FLUID
CONTAINED IN PEN. HOWEVER, COMPONENT IS EXTREMELY FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED.
Other Precautions:AVOID CONTACT WITH EYES, SKIN AND CLOTHING. USE WITH
ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES/HR)
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:EYE BATH, SAFETY SHOWER, WASHING FACILITIES.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:176F,80C
Vapor Pres:35.9 MMHG
Vapor Density:2.8
Spec Gravity:0.9
Solubility in Water:SLIGHT - MODERATE
Appearance and Odor:LIQUID, PINK, SLIGHT ODOR.
Percent Volatiles by Volume:>50
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NON-HAZARDOUS BASED ON LIMITED QUANTITY OF
FLUID CONTAINED IN PEN.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:MAY BE DISPOSED OF WITH GENERAL OFFICE WASTES.
DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT TO NATIONAL,
STATE, OR LOCAL LAWS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:STOP IT
CAGE:0DMC6
CAGE:0DMC6
============= Composition/Information on Ingredients =============
Ingred Name:FIBROUS GLASS
CAS:65997-17-3
Fraction by Wt: 50-55%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:P,P'-METHYLENEBIS(PHENYL ISOCYANATE) (METHYLENE BISPHENYL
ISOCYANATE,MDI)
CAS:101-68-8
RTECS #:NQ9350000
Fraction by Wt: 5-10%
Other REC Limits:N/K
OSHA PEL:0.02 PPM C
ACGIH TLV:0.005 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:POLYDIMETHYLSILOXANE
CAS:63148-62-9
RTECS #:JT6484500
Fraction by Wt: 1-5%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:P,P'METHYLENEBIS (PHENYL ISOCYANATE)-POLYPROPYLENE GLYCOL
PREPOLYMER
CAS:9048-57-1
Fraction by Wt: 35-40%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 MOUSE SKIN >2.0 G/KG,ORAL >5 G/KG.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS AND SYMPTOMS OF
OVEREXPOSURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:UNCURED PROD NOT EXPECTED TO CAUSE
IRRIT,IF USED AS DIRECTED.SKIN:PRLNG EXPOS MAY CAUSE SLIGHT
IRRIT.BASED ON MODIFIED HUMAN DRAIZE PATCH TEST:PROD IS NOT AN
IRRITANT OR ALLERGEN.CURED/ UNCURED P ROD NOT EXPECTED TO BE
SENSITIZING IF USED AS DIRECTED.INGEST:N/K .INHAL:NO SIGNIFICANT
HAZARD ON (SEE SUPP)
Medical Cond Aggravated by Exposure:N/K
======================= First Aid Measures =======================
First Aid:EYES:WASH IMMEDIATELY WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES AND CONSULT A PHYSICIAN.SKIN:WASH THOROUGHLY WITH SOAP AND
WATER.INGESTION:DRINK PLENTY OF WATER.DO NOT INDUCE VOMITING.
CONSULT A NU RSE OR PHYSICIAN.INHALATION:PROVIDE FRESH AIR,IF
BREATHING BECOMES DIFFICULT,CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:SEE SUPP DATA
Extinguishing Media:CARBON DIOXIDE,DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SELF CONTAINED
BREATHING APPARATUS AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NO UNUSUAL FIRE OR EXPLOSION HAZARDS.
HAZARDOUS DECOMPOSITION PRODUCTS:CARBON DIOXIDE,CARBON
MONOXIDE,TRACES OF OXIDES OF NITROGEN.FLASH BACK DOES NOT OCCUR.
================== Accidental Release Measures ==================
Spill Release Procedures:OBSERVE ALL PRECAUTIONS PROVIDED.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:OPTIMUM STORAGE 40-83F,4.44-28.33C.NO
SPECIAL CONDITIONS.MATERIAL WILL NOT REACT VIOLENTLY WITH AIR OR
WATER.
Other Precautions:PRODUCT WILL ADHERE TO CLOTHING.KEEP OUT OF THE REACH
OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Other Protective Equipment:N/K
Work Hygienic Practices:N/K
Supplemental Safety and Health
FLASH POINT:>220F,104.44C (UNCURED PRODUCT). ROUTES OF
ENTRY:INHALATION/SKIN/INGESTION .EFTS OF OVEREXPOS:REMOVAL OF CURED
MATERIAL.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Density:N/K
Evaporation Rate & Reference:N/K
Solubility in Water:N/K
Appearance and Odor:WHITE TO YELLOWISH,TACKY RESIN ON A FIBERGLASS
SUBSTRATE WITH VERY SLIGHT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MATERIAL WILL NOT REACT VIOLENTLY WITH AIR OR WATER.
Stability Condition to Avoid:N/K
Hazardous Decomposition Products:CARBON DIOXIDE,CARBON MONOXIDE,TRACES
OF OXIDES OF NITROGEN.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .SOLID WASTE LANDFILL OR
INCINERATE UNUSED/ SPENT MATERIAL.NO POISONOUS/HARMFUL/ACUTE
HAZARDOUS WASTE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS & NATURAL/SYNTHETIC RUBBER COMPOSITION
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SCOTCHGRIP BRAND VINYL ADHESIVE 2262
CAGE:76381
CAGE:76381
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE (SARA III)
CAS:67-64-1
RTECS #:AL3150000
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VINYL COPOLYMER
===================== Hazards Identification =====================
Effects of Overexposure:SLIGHT SKIN DEFATTING OR IRRITATION, NARCOSIS
OR DIZZINESS.
======================= First Aid Measures =======================
First Aid:SKIN: WASH WITH SOAP & WATER. EYES: FLUSH WITH WATER FOR 15
MINUTES. CALL PHYSICIAN. INHALATION: REMOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point:15F; 9.4C, (COC)
Extinguishing Media:CO*2, FOAM, DRY CHEMICALS
Fire Fighting Procedures:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP & DISCARD. AVOID IGNITION.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & OPEN
FLAME. USE IN WELL VENTILATED AREA.
============= Exposure Controls/Personal Protection =============
Ventilation:LOCAL EXHAUST RECOMMENDED TO KEEP BELOW TLV.
Supplemental Safety and Health
CONTAINER SIZE: 7.5 OZ CAN.
================== Physical/Chemical Properties ==================
Appearance and Odor:CLEAR
Percent Volatiles by Volume:75
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:MANUFACTURER RECOMMENDS INCINERATION. DISPOSAL
METHODS MUST BE IAW FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ION EXCHANGE RESIN, IONAC CFP-110/BZ
Preparer's Name:REGULATORY AFFAIRS
CAGE:76465
CAGE:76465
============= Composition/Information on Ingredients =============
Ingred Name:BENZENE DIETHENYL-, POLYMER WITH ETHENYLBENZENE AND
ETHENYLETHYLBENZENE, SULFONATED, SODIUM SALTS.
CAS:69011-22-9
Fraction by Wt: 40-60%
Ingred Name:WATER. VP: 17 @ 20C. VAP DENS: 0.62.
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 40-60%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC: CAN PRODUCE MECHANICAL
IRRITATION TO THE EYE. MAY CAUSE SKIN IRRITATION OF HYPERSENSITIVE
PERSONNEL.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:RED, IRRITATED EYES, ITCHING AND FEELING THAT A
PARTICLE EXISTS BETWEEN THE EYELID AND EYE.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH WITH COPIOUS QUANTITIES OF WATER FOR AT
LEAST 15 MINUTES. IF IRRITATION PERSISTS, SEE MD, AMERICAN RED
CROSS. INGEST: CALL MD IMMEDIATELY . INHAL: REMOVE TO FRESH AIR.
SUPPORT B REATHING (GIVE O*2/ARTIFICIAL RESPIRATION) .
===================== Fire Fighting Measures =====================
Flash Point:>200F,>93C
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE OR WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . GUARD AGAINST CONTACT OF PRODUCT WITH EYE
DURING SALVAGE OPERATION.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP AREA OF PRODUCT, COLLECTING IN A
CONTAINER FOR DISPOSAL. AREAS OF SPILL CAN BECOME EXTREMELY
SLIPPERY. ALL NORMAL SAFETY PRECAUTIONS SHOULD BE OBSERVED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID FREEZING/PRLNGD STORAGE >50C
BECAUSE PROD CONTAINS WATER WHICH WILL FREEZE & DAM PROD/DRY-OUT
ALSO DAMAGING PROD. AVOID CONT (SEE SUPP DATA)
Other Precautions:AVOID PACKING PROD IN AN UNPROTECTED GLASS COLUMN.
EXPANSION OF THE PROD CAN CAUSE GLASS COLUMN TO SHATTER. WHEN
TRANSFERRING PROD TO OTHER CNTNRS VIA HYDRAULIC (WATER) SLURRY ALL
SAFETY PRACTICES EST ABLISHED FOR USE OF WATER (SUPP DATA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:LONG SLEEVE SHIRT AND LONG TROUSERS ARE
RECOMMENDED TO PREVENT SKIN CONTACT.
Work Hygienic Practices:FLUSH PROD FROM HANDS W/SOAPY WATER. CARE
SHOULD BE TAKEN TO AVOID CONTACT W/EYES UNTIL HANDS HAVE BEEN (SEE
SUPP DATA)
Supplemental Safety and Health
PH: 6-9 IN AQUEOUS SLURRY. HNDLG/STOR PREC: WITH STRONG OXIDIZING
AGENTS SUCH AS NITRIC ACID. OTHER PREC: IN THE WORK SPACE MUST BE
OBSERVED. HYGIENE PRACT: COMPLETELY CLEANED. PROD HAS A TENDENCY TO
CLING TO SKIN DUE TO STATIC CHARGE. CARE MUST BE EXERCISED TO
REMOVE ALL PRODUCT FROM SKIN.
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Pres:SEE ING 2
Vapor Density:SEE ING 2
Spec Gravity:1.3
pH:SUPDAT
Evaporation Rate & Reference:1 (H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:SOLID SPHERICAL BEADS; ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS NITRIC ACID.
Stability Condition to Avoid:AT TEMPS ABOVE 204C DECOMPOSITION OCCURS.
EXPLOSIVE REACTIONS CAN OCCUR IN THE PRESENCE OF STRONG OXIDIZING
AGENTS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
STYRENE, DIVINYLBENZENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:NEW, UNUSED PRODUCT CAN BE DISPOSED OF AS
ORDINARY TRASH I/A/W ALL FEDERAL, STATE, AND LOCAL REGULATIONS.
USED PRODUCT MUST BE TESTED FOR CONTAMINATION BY HAZARDOUS MATERIAL
AND DISPOSED OF ACCORDINGL Y.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ENDURANCE OIL STAIN 9735
CAGE:EO697
CAGE:72818
CAGE:EO697
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 1-5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:ALKYD RESIN
CAS:67700-92-9
Fraction by Wt: 18-23%
Ingred Name:HYDROTREATED LIGHT DISTILLATE, PETROLEUM; C12-C15
ISOPARAFFINIC HYDROCARBONS
CAS:64742-47-8
Fraction by Wt: 66-71%
Other REC Limits:300 PPM (MFR)
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 1-5%
Other REC Limits:0.05 MG/CUM NIOSH
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF RESPIRATORY
TRACT, FATIGUE, DROWSINESS, DIZZINESS, HEADACHE, INCOORDINATION,
NAUSEA, COUGHING, & CENTRAL NERVOUS SYSTEM DEPRESSION. SKIN:
DERMATITIS & DEFATTING. EYES: BLURRE D VISION, TEARING, REDNESS, &
SEVERE IRRITATION. INGESTION: LUNG INFLAMMATION & DAMAGE.
Explanation of Carcinogenicity:CRYSTALLINE SILICA HAS BEEN DETERMINED
THAT THERE IS SUFFICIENT EVIDENCE FOR THE CARCINOGENICITY TO
ANIMALS.
Effects of Overexposure:INHALATION: PERMANENT BRAIN & NERVOUS SYSTEM
DAMAGE, NONCANCEROUS LUNG DISEASE, LIVER/KIDNEY DAMAGE,
UNCONSCIOUSNESS, RESPIRATORY FAILURE, ASPHYXIATION, & DEATH. SKIN:
DERMATITIS & DEFATTING. EYES: BL URRED VISION, TEARING, REDNESS, &
SEVERE IRRITATION. INGESTION: LUNG INFLAMMATION & DAMAGE.
Medical Cond Aggravated by Exposure:DERMATITIS
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE & SUPPORT BREATHING.
GET MED ATTN. SKIN: WASH W/PLENTY OF SOAP & WATER. WASH
CONTAMINATED CLOTHING BEFORE REUSE. EYES: FLUSH W/PLENTY OF WATER
FOR AT LEAST 15 MINUTES. INGESTION: GET MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:106F
Lower Limits:0.7%
Extinguishing Media:DRY CHEMICAL, FOAM
Fire Fighting Procedures:WATER MAY BE USED TO COOL & PROTECT EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT/FIRE. VAPORS CAN FORM EXPLOSIVE MIXTURES IN
AIR AT ELEVATED TEMPERATURES.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. VENTILATE
AREA. SPILLS MAY BE COLLECTED W/NON-COMBUSTIBLE ABSORBENT
MATERIALS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE <100F. AVOID CONTACT W/SKIN &
EYES. USE ONLY W/ADEQUATE VENTILATION. DON'T TAKE INTERNALLY. KEEP
OUT OF THE REACH OF CHILDREN.
Other Precautions:WASH HANDS AFTER HANDLING, BEFORE SMOKING/EATING.
KEEP CONTAINERS TIGHTLY CLOSED & UPRIGHT WHEN NOT IN USE. EMPTY
CONTAINERS MAY CONTAIN HAZARDOUS RESIDUES. GROUND EQUIPMENT WHEN
TRANSFERRING. AVOID S PRAYING/ABRADING PAINTED SURFACES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE RESPIRATORY PROTECTION IS REQUIRED, USE
ONLY NIOSH/MSHA APPROVED RESPIRATORS IN ACCORDANCE W/OSHA
STANDARDS.
Ventilation:PROVIDE MECHANICA/LOCAL EXHAUST VENTILATION TO PREVENT
BUILD-UPS OF VAPORS.
Other Protective Equipment:EYE WASH, SAFETY SHOWER
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING, BEFORE EATING &
SMOKING.
Supplemental Safety and Health
WT/GAL: 7.3 LBS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:308-374F
Percent Volatiles by Volume:78.3%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, BASES, AMINES
Stability Condition to Avoid:ELEVATED TEMPERATURES, HEAT, SPARKS, OPEN
FLAME, STATIC CHARGE, SOURCES OF IGNITION. STORAGE <100F.
Hazardous Decomposition Products:CO, CO2, TOXIC GASES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS. COMBUSTIBLE LIQUID.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ZINC OMADINE POWDER, INDUSTRIAL, CPE 135505
CAGE:8X135
CAGE:8X135
CAGE:53084
============= Composition/Information on Ingredients =============
Ingred Name:ZINC, BIS (2-PYRIDYLTHIO)-,N,N'-DIOXIDE;
(BIS(1-HYDROXY-2(1H)-PYRIDINETHIONATO-O,S)-(T-4)ZINC) 0.35 MG/M3;
8HR TWA (MFR)
CAS:13463-41-7
RTECS #:ZH0950000
Fraction by Wt: 95-100%
Other REC Limits:SEE INGREDIENT
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:2-PYRIDOL, 1-OXIDE
CAS:13161-30-3
Fraction by Wt: 0.5-1.5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM CHLORIDE
CAS:7647-14-5
RTECS #:VZ4725000
Fraction by Wt: 0.5-1.5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM SULFATE (2:1)
CAS:7757-82-6
RTECS #:WE1650000
Fraction by Wt: 0.5-1.5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 0.5-1.5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:EFTS OF OVEREXP:LETHARGY & DIARR. EYE:SEVERE IRRIT/&/CHEM
BURNS. CORNEAL OPACITY W/VISUAL IMPAIRMENT CAN OCCUR. (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:CHRONIC:INHAL:IRRIT TO RESP TRACT, SKELETAL MUSC
ATROPHY & PERIPHERAL NERVE DMG CHARACTERIZED BY GEN MUSC (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:WEAK HAVE BEEN RPTD IN SOME ANIMAL STUDIES. THESE
EFTS HAVE NOT BEEN OBSERVED IN PRIMATES, WHICH SUGGESTS (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:THAT HIND LIMB EFTS WOULD NOT OCCUR IN HUMANS.
INGESTION:THE PRODUCTION OF VOMITING WOULD PROVIDE (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:PRODUCTION OF VOMITING WOULD PROVIDE PROTECTION
AGAINST SYSTEMIC TOXICITY.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:ANYTHING BY MOUTH IF THE PERS IS UNCON/IF
HAVING CONVLS. INHAL:IF PERS EXPER NAUSEA, HDCH/DIZZ, (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:PERS SHOULD STOP WORK IMMED & MOVE TO FRESH AIR
UNTIL THESE SYMPS DISAPPEAR. IF BRTHG IS DFCLT, ADMIN (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:OXYGEN, KEEP THE PERS WARM & AT REST. CALL A MD. IN
EVENT THAT AN INDIVIDUAL INHALES ENOUGH VAP TO LOSE (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:CONSCIOUSNESS, PERS SHOULD BE MOVED TO FRESH AIR AT
ONCE & A MD SHOULD BE CALLED IMMED. IF BRTHG HAS (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:STOPPED, ARTF RESP SHOULD BE GIVEN IMMED. IN ALL
CASES, ENSURE ADEQ VENT & PROVIDE RESP PROT BEFORE PERS (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:RETURNS TO WORK.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:W/OTHER MATLS UNLESS EXCESSIVE DUSTING OCCURS &
THEN ADD SAND/COMMERCIAL ABSORBENT & CONTAINERIZE. (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:AS A FINAL MEASURE ADD H*2O TO SOLIDIFY MATL AFTER
INSTALLING A PROPER DIKE TO CONTAIN THE MIX. REMOVE (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:IN A LIQUID FORM, CONTAINERIZE AND LABEL PROPERLY.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:DURING SHIPPING, UNLOADING, POURING/CONVEYING.
TO AVOID FIRE/EXPLOSION, GROUND & BONE CNTNR RECEIVING(ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20:PERS (& GROUND PERS) BEFORE TRANSFERRING MATL. CARE
MUST BE TAKEN TO PVNT ENVIRON CONTAM FROM THE USE OF (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21:THIS MATL. FOR MORE SPECIFIC INFORMATION CONTACT
NEHC .
RTECS #:9999999ZZ
Ingred Name:OTHER PROT EQUIP:ADDNL RESP PROT IS NEC WHEN A SPILL
INVOLVING THIS PROD OCCURS. NIOSH APPRVD RESP W/HEPA (ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23:FILTERS RECOMMENDED. FOR MORE SPECIFIC INFORMATION
CONTACT NEHC .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT):269 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:WARNING STATEMENTS & WARNING
PROPERTIES: MAY BE HARMFUL IF INHALED/SWALLOWED. CORR TO EYES. MAY
CAUSE SKIN & RESP IRRIT. ACUTE:INHAL:OVEREXPOS TO DUST MAY BE
HARMFUL. INHAL OF LOW LEVELS OF DUST MAY C AUSE MILD IRRIT TO
THROAT, UPPER RESP TRACT & LUNGS. ANY IRRIT WOULD BE TRANSIENT W/NO
PERMANENT DMG (EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:EXPECTED. CLINICAL SIGNS FROM EXPOS
MAY INCL TREMORS, ATAXIA & CONVULS. SKIN:CNTCT MAY CAUSE IRRIT
CONSISTING OF TRANSIENT REDNESS. THIS IRRITANT EFT WOULD NOT RSLT
IN PERM DMG. CLINICAL SIGN S OF TOX WOULD BE SIMILAR TO THOSE
OBSERVED FROM INHAL EXPOS. INGEST:MAY BE HARMFUL IF SWALLOWED. IF
SMALL (SUPDAT)
Medical Cond Aggravated by Exposure:DISEASES OF MUSCLE AND NERVE, E.G.
MUSCULAR DYSTROPHY OF MULTIPLE SCLEROSIS, MAY BE AGGRAVATED BY
EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYES:IMMED FLUSH W/LRG AMTS OF H*2O FOR AT LEAST 15 MIN,
OCCAS LIFTING THE UPPER & LOWER EYELIDS. CALL A MD AT ONCE.
SKIN:IMMED FLUSH W/H*2O FOR AT LEAST 15 MIN. WASH THE CONTAMD SKIN
W/SOAP & H*2O. I F IRRIT DEVELOPS, CALL MD. IF CLTHG COMES IN CNTCT
W/THE PROD, THE CLTHG SHOULD BE LAUNDERED BEFORE REUSE.
INGEST:IMMED DRINK LRG QTIES OF H*2O. INDUCE VOMIT. CALL MD AT
ONCE. DO NOT GIVE (ING 11)
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:CARBON DIOXIDE, WATER SPRAY.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . USE WATER TO COOL CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP SOURCE OF SPILL AS SOON AS POSS & NOTIFY
APPROP PERS. H*2O RLS:HEAVIER THAN H*2O. MATL IS ONLY SLIGHTLY SOL
IN H*2O. STOP H*2O FLOW/DIVERT AROUND SPILL IF POSS. LAND
SPILL:REMOVE/CLEAN UP MATL IN POWDER FORM IF POSS. DO NOT
CONTAMINATE (ING 17)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE AT TEMPS ABOVE:54 DEG.C
(130 DEG.F). AVOID CONTACT WITH SKIN, EYES & CLOTHING. UPON CONTACT
WITH SKIN/EYES, WASH OFF WITH WATER.
Other Precautions:DO NOT EXPOSE TO DIRECT LIGHT. AS W/OTHER COMBUST
MATLS, AVOID STOR & HNDLG CNDTNS WHICH LEAD TO FORMATION OF DUST
CLOUDS. DUST CLOUDS ARE SUSCEPTIBLE TO IGNIT BY ELEC (STATIC)
DISCHARGE. STATIC CHARG ES CAN ACCUM DURING SHIPPING, (ING 20)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH APPROVED RESPIRATOR IF EXPOSURE
ABOVE OLIN'S INTERNAL STANDARD ARE POSSIBLE.
Ventilation:USE LOCAL EXHAUST VENTILATION TO MAINTAIN LEVELS BELOW
OLIN'S INTERNAL STANDARD.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . IMPERVIOUS BOOTS, APRON, PROT SUITE. (ING
23)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:QTIES ARE INGESTED, VOMIT WILL NORMALLY OCCUR (USUALLY
W/IN 5-10 MIN). ZINC OMIDINE IS AN EMETIC & DUE TO THIS PROPERTY OF
THE PROD, IT IS UNLIKELY THAT SIGNIFICANT QTIES OF MATL WOULD BE
ABSORBED ACROSS THE GI TRACT TO PRDCE SERIOUS TOX EFTS. HOWEVER,
INGEST MAY PRDCE GI IRRIT W/NAUS VOMIT, (ING 6)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:DECOMPOSES
Melt/Freeze Pt:M.P/F.P Text:464F,240C
Decomp Temp:Decomp Text:392F,200C
Vapor Pres:NEGLIGIBLE
Spec Gravity:1.78
pH:6.5-9
Solubility in Water:0.0008% (8 PPM)
Appearance and Odor:OFF-WHITE TO TAN POWDER; NO ODOR
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:DIRECT EXPOSURE TO ULTRAVIOLET RADIATION
CAUSES SLOW DECOMPOSITION.
Hazardous Decomposition Products:CARBON MONOXIDE, SULFUR DIOXIDE,
NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:IT SHOULD BE DISPOSED OF IN ACCORDANCE WITH
LOCAL, STATE, AND FEDERAL REGULATIONS BY DISPOSAL IN A SECURE
CHEMICAL LANDFILL. FOR MORE SPECIFIC INFORMATION ON WASTE DISPOSAL
METHOD CONTACT NEHC .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CASTROL GPM 4-STROKE MOTORCYCLE OIL
Preparer's Name:MICHAEL P. SHEEHAN
CAGE:DO089
CAGE:DO089
============= Composition/Information on Ingredients =============
Ingred Name:NO HAZARDOUS MATERIALS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:NOT EXPECTED TO CAUSE ANY ILL EFFECT
EXCEPT POSSIBLY IN VERY SENSITIVE INDIVIDUALS.MAY CAUSE EYE
IRRITATION.AVOID CONTACT WITH EYES.
Effects of Overexposure:SAME AS ACUTE AND CHRONIC EXPOSURE
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE FROM AREAS OF VAPOR. EYES:FLUSH WITH CLEAR
WATER UNTIL IRRITATION SUBSIDES.CONTACT A PHYSICIAN AS SOON AS
POSSIBLE.SKIN:WIPE OR USE WATERLESS HANDCLEANER,WASH SKIN WITH SOAP
AND WATE R.INGESTION:DO NOT INDUCE VOMITING, CONTACT A
PHYSICIAN.DONT GIVE LIQUIDS IF VICTIM IS UNCONSCIOUS.SMALL AMOUNTS
WHICH MAY ACCIDENTALLY ENTER THE MOUTH SHOULD BE RINSED OUT UNTIL
NO TASTE REMAINS.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:355F
Lower Limits:1.0
Upper Limits:6.0
Extinguishing Media:DRY CHEMICAL,CARBON DIOXIDE,FOAM,WATER FOG
Fire Fighting Procedures:USE AIR-SUPPLIED RESCUE EQUIPMENT FOR ENCLOSED
AREAS.COOL EXPOSED CONTAINERS WITH WATER
Unusual Fire/Explosion Hazard:DO NOT STORE OR MIX WITH STRONG
OXIDANTS.PRODUCTS OF COMBUSTION:SMOKE,FUMES,HYDROCARBONS,CARBON
DIOXIDE,CARBON MONOXIDE&SMALL QNTYS OF OXIDES OF SULFUR&NITROGEN
================== Accidental Release Measures ==================
Spill Release Procedures:MOP OR WIPE UP OR ABSORB WITH
CLAY,DIATOMACEOUS EARTH OR OTHER INERT MATERIAL AND STORE IN CLOSED
METAL CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL PRECAUTIONS. AMBIENT
CONDITIONS ACCEPTABLE,BUT DO NOT STORE NEAR EXTREME HEAT,OPEN
FLAME,OR SOURCES OF IGNITION.
Other Precautions:AVOID BREATHING OF OIL,MIST.REMOVE OIL IMPREGNATED
CLOTHING.WASH THOROUGHLY AFTER EXPOSURE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY NEEDED.USE SUPPLIED AIR (SPECIFY
TYPE) RESPIRATORY PROTECTION IN CONFINED OR ENCLOSED AREAS.
Ventilation:MAINTAIN EXPOSURE BELOW 5MG PER CUBIC METER. FAN IF NEEDED.
Other Protective Equipment:USE CHEMICALLY RESISTANT APRON OR OTHER
CLOTHING TO AVOID PROLONGED SKIN CONTACT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:500F
Vapor Pres:.01
Vapor Density:1.0
Spec Gravity:0.88-0.90
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR,AMBER TO BROWN COLORED,OILY LIQUID,VERY
SLIGHT HYDROCARBON ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZING AGENTS LIKE LIQUID CHLORINE AND CONCENTRATED
OXYGEN
Hazardous Decomposition Products:COMBUSTION MAY PRODUCE SMOKE,CARBON
MONOXIDE AND OXIDES OF SULFUR AND NITROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED INCINERATION OR METHOD IN COMPLIANCE
WITH LOCAL,STATE AND FEDERAL REGULATIONS REGARDING HEALTH,AIR AND
WATER POLLUTION.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:208A154 BLACK WALNUT, PENETRATING OIL WOOD
CAGE:ACEHA
CAGE:ACEHA
============= Composition/Information on Ingredients =============
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (MINERAL SPIRITS 140
FLASH). VP: 0.5
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 8%
OSHA PEL:500 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (MINERAL SPIRITS). VP:
2.0
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 67%
OSHA PEL:500 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL IS ANESTHETIC. IRRITATION OF
RESPIRATORY TRACT OR NERVOUS SYSTEM DEPRESSION. HEADACHE,
DIZZINESS, NAUSEA, CONFUSION, UNCONSCIOUSNESS OR COMA. SKIN OR EYE
CONTACT: PRIMARY IRRITATION. REPORTS HAV E ASSOCIATED REPEATED AND
PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN & NERV SYSTEM DAMAGE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM EXPOSURE. RESTORE BREATHING, KEEP WARM AND
QUIET, NOTIFY PHYSICIAN. EYES: FLUSH IMMEDIATELY WITH RUNNING WATER
FOR AT LEAST 15 MIN. SKIN: WASH WITH SOAP AND WATER AND APPLY SKIN
CRE AM. NOTIFY PHYSICIAN IN ALL CASES. INGEST: GET MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:105F,41C
Lower Limits:0.9%
Extinguishing Media:FOAM, "ALCOHOL" FOAM, DRY CHEMICAL.
Fire Fighting Procedures:DURING EMERGENCY CNDTNS OVEREXP TO DECOMP PROD
MAY CAUSE HLTH HAZ. SYMP MAY NOT BE IMMED APPARENT. GET MED ATTN.
NIOSH/MSHA APPRVD SCBA & FULL PROT (SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT/ ELEC EQUIP/SPARKS/OPEN FLAME. HEAT MAY CAUSE PRESSURE
BUILD-UP IN CLOSED CONTAINERS, WATER MAY BE USED TO COOL.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DOL STORAGE CATEGORY-2. CONTENTS ARE
COMBUSTIBLE, KEEP AWAY FROM HEAT & OPEN FLAME. USE ONLY WITH
ADEQUATE VENTILATION. AVOID BRTHG VAP & SPRAY MIST.
Other Precautions:AVOID CONTACT WITH SKIN AND EYES. KEEP CNTNR CLOSED
WHEN NOT IN USE. DO NOT TRANSFER CONTENTS TO OTHER CNTNRS FOR
STORAGE. DO NOT TAKE INTERNALLY, KEEP OUT OF REACH OF CHILDREN.
CONSULT NFPA CODE. USE APPRVD BONDING & GROUNDING PROCEDURES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING AND ADMINISTRATIVE CONTROLS OF
AIR CONTAMINANTS ARE NOT POSSIBLE, USE NIOSH/MSHA APPROVED
RESPIRATORY DEVICES FOR PROTECTION AGAINST SPRAY MIST AND VAPORS.
Ventilation:LOCAL EXHAUST PREFERABLE. MECHANICAL (GENERAL) EXHAUST
ACCEPTABLE. SPECIAL VENTILATION REQUIRED TO KEEP BELOW TLV & LEL.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:REMOVE AND WASH CONTAMINATED CLOTHING, DISCARD
CONTAMINATED SHOES. WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC: EQUIPMENT SHOULD BE USED . WATER SPRAY MAY BE
INEFFECTIVE. WATER MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT
PRESSURE BUILDUP AND POSSIBLE AUTOIGNITION OR EXPLOSION WHEN EX
POSED TO EXTREME HEAT.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:308F,153C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:1.06
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:88.4
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:HIGH TEMPERATURES, OPEN FLAME.
Hazardous Decomposition Products:BY FIRE: CO2, CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS. DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE, AND LOCAL REGULATIONS REGARDING POLLUTION.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:COMPASSES CB2100T4-A, CR2100-4
CAGE:70214
Contract Num:SP0440-00-M-N180
CAGE:70214
Contract Num:SP0440-97-C-5348
CAGE:70214
============= Composition/Information on Ingredients =============
Ingred Name:C*10-C*13-ISOALKANES
CAS:68551-17-7
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: MAY CAUSE
IRRITATION OF RESPIRATORY SYSTEM AND CENTAL NERVOUS SYSTEM
DEPRESSION. MAY IRRITATE SKIN AND EYES ON CONTACT. MAY IRRITATE
DIGESTIVE SYSTEM IF SWALLOWED. ASPIRATION HAZARD . CHRONIC: NONE
SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSUPECTED CARCINOGEN.
Effects of Overexposure:INHALATION: DIZZINESS, HEADACHE, NAUSEA,
UNCONSCIOUS. EYES: REDNESS, TEARING, BLURRED VISION. SKIN:DRYNESS,
ITCHING. INGESTION: NAUSEA, VOMITING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALAED: REMOVE PERSON TO FRESH AIR. EYES: FLUSH WITH LOTS
OF WATER FOR 15 MINUTES. SEE DOCTOR. SKIN: WASH WITH SOAP AND
WATER. INGESTED: DO NOT INDUCE VOMITING. IF VOMITIND OCCURS, KEEP
HEAD BELOW K NEES. GET IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:=56.1C, 133.F
Extinguishing Media:DRYCHEMICAL, FOAM, CARBON DIOXIDE
Fire Fighting Procedures:SHUT OFF SOURCE. USE WATER FOG OR SPRAY TO
COOL EXPOSED EQUIPMENT AND CONTAINERS. WEAR SELF-CONTAINED
BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:COMBUSTIBLE LIQUID. PROTECT FROM SOURCES
OF IGNITION.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. CONTAIN
SPILL. VENTILATE AREA. ABSORB WITH VERMICULITE OR SIMILAR MATERIAL
AND PLACE IN A CONTAINER FOR LATER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY WELL VENTILATED
AREA.AVOID INHALATION AND SKIN AND EYE CONTACT. WEAR PROTECTIVE.
WASH HANDS BEFORE EATING, DRINKING OR SMOKING.
Other Precautions:BOND AND GROUND DURING LIQUID TRANSFER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED UNLESS NEEDED TO PROTECT
RESPIRAORY IRRITATION.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION.
Other Protective Equipment:USE PROTECTIVE GARMENTS TO PREVENT SKIN
IRRITATION.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
SEE P/N: C FOR ADDITIONAL INFORMATION. MSDS WRITTEN FOR THE LIQUID
INSIDE THE COMPASS. IF COMPASS BREAKS AND LIQUID RELEASES: USE
NEED SAFETY GLASSES.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:=176.C, 348.8F
B.P. Text:349F,176C
Vapor Pres:2 @ 70F
Vapor Density:>1
Spec Gravity:0.75
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIQUID INSIDE COMPASS HOUSING; PETROLEUM ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXYGEN OR STRONG OXIDIZING MATERIALS
Hazardous Decomposition Products:OXIDES OF CARBON
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. MANUFACTURER SAYS TO INCINERATE LIQUID IN AN
APPROVED FACILITY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DISCOVERY 2000
CAGE:DO351
CAGE:DO351
CAGE:28745
============= Composition/Information on Ingredients =============
Ingred Name:DIPROPYLENE GLYCOL, MONOMETHYL ETHER;(DIPROPYLENE GLYCOL
METHYL ETHER)
CAS:34590-94-8
RTECS #:JM1575000
Fraction by Wt: 1-3%
OSHA PEL:100 PPM;150 STEL, S
ACGIH TLV:100 PPM;150 STEL, S
Ingred Name:PHTHALIC ACID, DIBUTYL ESTER;(DIBUTYL PHTHALATE)
CAS:84-74-2
RTECS #:TI0875000
Fraction by Wt: 1-3%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Ingred Name:ACRYLIC COPOLYMER;(ACRYLIC COPOLYMER EMULSION)
Ingred Name:ETHANOL, 2-(2-ETHOXYETHOXY)-;(DIETHYLENE GLYCOL MONOETHYL
ETHER)
CAS:111-90-0
RTECS #:KK8750000
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:MILD EYE IRRITATION.
CHRONIC:NONE KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NONE KNOWN.
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:EYE:IF SPLASHED INTO EYES FLUSH WITH WATER FOR AT LEAST 15
MINUTES; IF WEARING CONTACT LENSES REMOVE AND FLUSH AGAIN WITH
PLENTY OF WATER. IF IRRITATION PERSISTS GET MEDICAL ATTENTION.
INHAL: REMOVE T O FRESH AIR. SUPPORT BREATHING GIVE O2/ARTF RESP) .
INGEST: CALL MD IMMEDIATELY . SKIN: FLUSH WITH COPIOUS AMOUNTS OF
WATER. CALL MD .
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Extinguishing Media:USE EXTINGUISHING MEDIA SUITABLE FOR SURROUNDING
AREA .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MATERIAL MAY SPATTER IF TEMPERATURES
EXCEED BOILING POINT. POLYMER FILM CAN BURN.
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP WITH MOP OR WET VAC AND WASH AWAY WITH
WATER. WASH SMALL QUANTITIES DOWN SEWER W/LG AMT OF WATER. KEEP
SPILLS AND CLEANING RUNOFFS OUT OF MUNICIPAL SEWERS AND OPEN BODIES
OF WATER. LARGE SPILL S SHOULD BE PICKED UP W/WET VAC OR ABSORBENT
MATL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:FREEZING OF PRODUCT MAY RUPTURE
CONTAINER. PRODUCT SHELF LIFE IS BEST RETAINED BY STORAGE AT
45-100F TEMPERATURES.
Other Precautions:INHALATION EXPOSURES TO SPRAY MIST SHOULD BE
MAINTAINED AT LESS THAN 10 MG/M3 PER EIGHT HOUR EXPOSURE (TWA LIMIT
EST. FOR NUISANCE DUST.)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED. NIOSH/MSHA APPROVED RESPIRATORY
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:AT LEAST 10 AIR CHGS/HR. RECOMMENDED. MECHANICAL
VENTILATION.
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:DONT TAKE INTERNALLY; WASH CONTAMINATED
CLOTHING BEORE REUSE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:206F,97C
Vapor Pres:18.74
Vapor Density:1.120
Spec Gravity:1.026 @ 25C
Evaporation Rate & Reference:<1 ETHYL ETHER=1)
Solubility in Water:APPRECIABLE
Appearance and Odor:WHITE EMULSION, NON-OBJECTIONABLE ODOR.
Percent Volatiles by Volume:83.89
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL OR INCINERATE SOLIDS. DISPOSE OF LIQUID
PER LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:REFRACTIVE INDEX LIQUIDS SERIES B, 18122
CAGE:IO084
CAGE:10684
CAGE:IO084
============= Composition/Information on Ingredients =============
Ingred Name:2-NAPHTHOL, 1-IODO-; (1-IODONAPHTHALENE)
CAS:2033-42-3
RTECS #:QL4150000
Other REC Limits:5 MG/M3 (MFR)
Ingred Name:1-BROMONAPHTHALENE
Other REC Limits:5 MG/M3 (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE KNOWN AT CONDITIONS OF INTENDED
USE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:OILY FEEL, IF LIQUID IS MISTED OR ABOVE 150F
(NOT A CONDITION OF INTENDED USE) HEADACHES & NAUSEA POSSIBLE.
Medical Cond Aggravated by Exposure:NO DATA FOUND.
======================= First Aid Measures =======================
First Aid:INHAL: IF CONCERN ARISES REMOVE TO FRESH AIR AND ADMINISTER
OXYGEN OR ARTIFICIAL RESPIRATION. SKIN: PROMPT SOAP AND WATER WASH.
CALL MD IF SKIN IS IRRITATED. EYE: FLUSH WITH WATER FOR AT LEAST 15
MINU TES, SLIGHT TEMPORARY IRRITATION POSSIBLE. CALL MD. INGEST: DO
NOT INDUCE VOMITING. DRINK 1-2 GLASSES OF WATER OR MILK. CALL MD.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>199F,>93C
Extinguishing Media:CARBON DIOXIDE, FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:NONE. WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB, PLACE IN PLASTIC CONTAINER, CAP OR
TWIST TIE CLOSURE, WASH AREA WITH DETERGENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM CONTACT WITH OXIDIZING
MATERIALS. STORE BETWEEN 39F AND 104F.
Other Precautions:AVOID CONTINUAL DIRECT LIGHT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST: MANDATORY IF A WORKER IS SENSITIVE TO ODOR.
OTHER: NORMAL ROOM AIR CHANGES/HR:2.
Other Protective Equipment:NOT MANDATORY EXCEPT AS GOOD LAB INDUSTRIAL
PRACTICES.
Work Hygienic Practices:ALWAYS USE GOOD HYGIENIC WORK/PRACTICES AS TO
HOUSEKEEPING, PERSONAL HYGIENE, USE OF CHEM LAB APRON, (SEE SUPP
DATA)
Supplemental Safety and Health
SKIN CONTACT.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>534F,>279C
Melt/Freeze Pt:M.P/F.P Text:39.0F,3.9C
Vapor Pres:1 (@ 73F)
Vapor Density:1 (@ 73F)
Spec Gravity:1.49-1.75
Evaporation Rate & Reference:1 (MINERAL OIL=1)
Solubility in Water:PRACTICALLY INSOL
Appearance and Odor:YELLOW OILY LIQUID; PUNGENT TO MOTH BALL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, HEAT ABOVE 150F. COMBUSTION WILL PRODUCE CARBON
DIOXIDE AND PROBABLY CARBON MONOXIDE.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:ALL CHEMICAL DISPOSAL MUST BE DISPOSED I/A/W
CURRENT LOCAL, STATE, AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:L61W100 OPEX L61 PRODUCTION LACQUER WHITE
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:ISOPARAFFINIC HYDROCARBONS (NAPHTHA PETROLEUM),
HYDROTREATED HEAVY, NON AROMATIC HEAVY NAPHTHA) ISOPAR G
CAS:64742-48-9
Fraction by Wt: 9%
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:TOLUENE (IARC CARC- GROUP 3) *94-4*
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 3%
Other REC Limits:375 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *94-4*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 3%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 5%
Other REC Limits:400 PPM
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
Ingred Name:ISOBUTANOL, 2-METHYL-1-PROPANOL, ISOBUTYL ALCOHOL
CAS:78-83-1
RTECS #:NP9625000
Fraction by Wt: 5%
Other REC Limits:50 PPM
OSHA PEL:50 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-BUTOXYETHANOL (ETHYLENE GLYCOL MONOBUTYL ETHER), BUTYL
CELLOSOLVE, BUTYL GLYCOL, GLYCOL ETHER EB
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 3%
Other REC Limits:25 PPM (SKIN)
OSHA PEL:25 PPM (SKIN)
ACGIH TLV:25 PPM (SKIN)
Ingred Name:2-BUTANONE (METHYL ETHYL KETONE) (MEK)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 2%
Other REC Limits:590 MG/CUM
OSHA PEL:200 PPM
ACGIH TLV:200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:HEXONE, METHYL ISOBUTYL KETONE (MIBK), 4-METHYL-2-PENTANONE
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 1%
Other REC Limits:50 PPM
OSHA PEL:50 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOBUTYL ACETATE, ESTER
CAS:110-19-0
RTECS #:AI4025000
Fraction by Wt: 17%
Other REC Limits:150 PPM
OSHA PEL:150 PPM
ACGIH TLV:150 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TITANIUM DIOXIDE, TIO2 (SUSPECTED ANIMAL CARCINOGEN BY
IARC-GROUP 3) *94-4*
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 17%
OSHA PEL:10 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:VOLATILE ORGANIC COMPOUNDS: 4.68 LBS/GAL
RTECS #:9999999VO
Ingred Name:LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA, LACOLENE
CAS:64742-89-8
Fraction by Wt: 3%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF EYES/SKIN/RESPIRATORY
SYSTEM/MAY CAUSE NERVOUS SYSTEM DEPRESSION. EXTREME OVEREXPOSURE
MAY CAUSE DEATH. METHYL ETHYL KETONE INCREASES NERVOUS SYSTEM
EFFECTS OF OTHER SOLVENTS. OVEREXPOSU RE TO SOLVENTS CAUSES ADVERSE
EFFECTS OF LIVER/URINARY/BLOOD FORMING/CARDIOVASCULAR/REPRODUCTIVE
SYSTEMS. (SEE SUPP)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, UNCONSCIOUSNESS, HEADACHE,
DIZZINESS, NAUSEA, LOSS OF COORDINATION, REDNESS, ITCHING, BURNING
SENSATION.
Medical Cond Aggravated by Exposure:N/K
N.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. KEEP WARM
& QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY W/SOAP & WATER. EYES:
FLUSH W/LARGE AMOUNTS OF WATER FOR 15 MINS. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:21-35F
Lower Limits:0.5
Upper Limits:36.5
Extinguishing Media:CO2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR SCBA & FULL PROTECTIVE EQUIPMENT. WATER
SPRAY MAY BE INEFFECTIVE, BUT MAY BE USED TO COOL CLOSED
CONTAINERS. IF WATER IS USED, FOG NOZZLES ARE PREFERABLE.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. VENTILATE &
REMOVE W/INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:USE IN WELL VENTILATED AREA. KEEP
CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. KEEP AWAY FROM
HEAT/SPARKS/OPEN FLAME/OTHER IGNITION SOURCES.
Other Precautions:FLAMMABLE. DON'T SMOKE. USE APPROVED BONDING &
GROUNDING PROCEDURES. TRANSFER ONLY TO APPROVED CONTAINERS
W/COMPLETE & APPROPRIATE LABELING. DON'T TAKE INTERNALLY. KEEP OUT
OF REACH OF CHILDREN. AVOID BREATHNG VAPOR/SPRAY MIST. (SEE SUPP)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A PROPERLY FITTED NIOSH/MSHA APPROVED
ORGANIC VAPOR/PARTICULATE RESPIRATOR IF PERSONAL EXPOSURE CAN'T BE
CONTROLLED BELOW APPLICABLE LIMITS BY VENTILATION, A PARTICULATE
RESPIRATOR WHEN SANDING/W IREBRUSHING/ABRADING/WELDING/BURNING.
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST IS ACCEPTABLE IF
EXPOSURE IS MAINTAINED BELOW APPLICABLE EXPOSURE LIMITS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS AFTER USING.
Supplemental Safety and Health
HEALTH HAZARDS CONT'D: REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS
CAUSES PERMANETN BRAIN & NERVOUS SYSTEM DAMAGE. OTHER PRECAUTIONS
CONT'D: AVOID CONTACT W/SKIN & EYES. INTENTIONAL MISUSE BY DELIBERA
TELY CONCENTRATING & INHALING CONTENTS CAN BE HARMFUL/FATAL.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:148-395F
Vapor Density:>1
Spec Gravity:0.83-1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:68-91
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:EXTREME HEAT, ELECTRICAL EQUIPMENT,
SPARKS, OPEN FLAME & OTHER IGNITION SOURCES.
Hazardous Decomposition Products:CO, CO2, METAL OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DON'T
INCINERATE CLOSED CONTAINER. DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DMR451 DELSTAR DARK PERMANENT RED ENAMELS
CAGE:47695
CAGE:47695
============= Composition/Information on Ingredients =============
Ingred Name:QUINACRIDOE VIOLET
*92-3*
CAS:1047-16-1
Fraction by Wt: 1-2%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 50-55%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:FILM FORMERS
Fraction by Wt: <45%
Ingred Name:RESIN
Fraction by Wt: <45%
Other REC Limits:10 MG/CUM (DUST)
Ingred Name:ADDITIVES
Fraction by Wt: <45%
Ingred Name:WEIGHT PER GALLON IN POUNDS: 7.97
RTECS #:9999999WG
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: HARMFUL OR FATAL.
EYES/SKIN: IRRITATION. INHALATION: IRRITATION OF EYES, NOSE, &
THROAT, HARMFUL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: EYE WATERING, HEADACHES, NAUSEA,
DIZZINESS, LOSS OF COORDINATION, PERMANENT BRAIN & NERVOUS SYSTEM
DAMAGE. EYES: REDNESS, ITCHING, BURNING SENSATION & VISUAL
DISTURBANCES. SKIN: DRYNESS, I TCHING, CRACKING, BURNING, REDNESS,
& SWELLING.
======================= First Aid Measures =======================
First Aid:INGESTION: DON'T INDUCE VOMITING. EYES: FLUSH IMMEDIATELY
W/PLENTY OF WATER FOR AT LEAST 15 MINS. SKIN: FLUSH IMMEDIATELY
W/PLENTY OF WATER, FOLLOWED BY WATERLESS HAND CLEANER & SOAP &
WATER. INHALATI ON: REMOVE TO FRESH AIR. APPLY ARTIFICIAL
RESPIRATION & OTHER SUPPORTIVE MEASURES. OBTAIN MEDICAL ATTENTION
IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:79F
Lower Limits:1.1%
Extinguishing Media:CO2, DRY CHEMICAL, OR UNIVERSAL AQUEOUS FILM
FORMING FOAM
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE, BUT MAY BE
USED TO COOL CLOSED CONTAINERS. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE. WEAR SCBA.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS EXPOSED TO EXTREME HEAT
MAY EXPLODE/BUILD-UP PRESSURE/AUTOIGNITE. FLAMMABLE LIQUID.
================== Accidental Release Measures ==================
Spill Release Procedures:PROVIDE MAXIMUM VENTILATION. EVACUATE AREA OR
WEAR PROTECTIVE EQUIPMENT. REMOVE ALL SOURCES OF IGNITION. TAKE UP
SPILLED MATERIAL W/SAWDUST/VERMICULITE/OTHER ABSORBENT MATERIAL &
PLACE INTO CONTAINERS FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE >120F. STORE LARGE
QUANTITIES IN BUILDINGS DESIGNED/PROTECTED FOR STORAGE OF NFPA
CLASS IC FLAMMABLE LIQUIDS. KEEP CONTAINERS TIGHT.
Other Precautions:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING &
INHALING CONTENTS CAN BE HARMFUL OR FATAL. CONTAINERS SHOULD BE
GROUNDED WHEN POURING. AVOID FREE FALL OF LIQUIDS IN EXCESS OF FEW
INCHES. AVOID CONT ACT W/EYES & SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED (TC23C) AIR
PURIFYING/AIR SUPPLIED (TC19C) RESPIRATORS TO REDUCE EXPOSURE.
Ventilation:GENERAL DILUTION OR LOCAL EXHAUST: IN VOLUME & PATTERN TO
KEEP CONCENTRATION BELOW LIMITS. PROVIDE FRESH AIR ENTRY.
Other Protective Equipment:IMPERMEABLE APRON & OTHER PROTECTIVE
CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE.
Supplemental Safety and Health
PERCENT SOLID BY WEIGHT: 45.56. IF MATERIAL IS PART OF A MULTIPLE
COMPONENT COATING SYSTEM, READ THE MSDS'S FOR THE OTHER COMPONENT
OR COMPONENTS BEFORE BLENDING AS THE RESULTING MIXTURE MAY HAVE THE
HAZARDS OF ALL OF ITS PARTS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:280-399F
Vapor Pres:4.9
Vapor Density:>1
Spec Gravity:0.96
Evaporation Rate & Reference:(BU AC = 100): 62
Solubility in Water:INSOLUBLE
Appearance and Odor:VISCOUS LIQUID W/ODOR CHARACTERISTIC OF SOLVENTS.
Percent Volatiles by Volume:60.10%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, STRONG MINERAL ACIDS, & STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXTREME HEAT/ELECTRICAL
EQUIPMENT/SPARKS/OPEN FLAMES/HOT SURFACES/TEMPS >120F/OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:TOXIC GASES OF CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. EMPTY CONTAINERS SHOULD BE RECYCLED OR
DISPOSED OF THROUGH AN APPROVED WASTE MANAGEMENT FACILITY.
FLAMMABLE LIQUID. UN 1263.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SA 826 3242
Preparer's Name:RAY LAWSON
CAGE:70878
CAGE:70878
============= Composition/Information on Ingredients =============
Ingred Name:"NOT HAZARDOUS"
Fraction by Wt: 100%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS NOT AVAILABLE
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC- NONE WHEN USED WITH
GOOD PERSONAL HYGIENE PRACTICES. MAY OTHERWISE CAUSE SKIN AND EYE
IRRITATION UPON PROLONGED OR REPEATED CONTACT. INHALATION OR
INGESTION MAY BE HARMFUL.
Effects of Overexposure:PROLONGED OR REPEATED EYE OR SKIN CONTACT MAY
CAUSE IRRITATION.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN DISORDERS MAY BE
AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION.INHALATION:REMOVE TO FRESH AIR.PROVIDE
OXYGEN IF NEEDED.INGESTION:DO NOT INDUCE VOMITING.CALL A PHYSICIAN
IMMEDIATELY.EYE:FLUSH WITH WATER FOR 15 MINUTES,HOLDING EYELIDS
OPEN.SKI N:WIPE EXCESS OFF.WASH SKIN WITH SOAP &WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>410F,>210C
Extinguishing Media:WATER FOG, CO2, DRY CHEMICAL, SAND/EARTH. WATER MAY
CAUSE FROTHING. COOL FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS WITH FULL
FACEPIECE OPERATED IN THE POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:DENSE SMOKE
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP UP EXCESS GREASE. ABSORB RESIDUE WITH AN
INERT MATERIAL SUCH AS EARTH, SAND OR VERMICULITE. SWEEP UP AND
TRANSFER TO A CONTAINER FOR PROPER DISPOSAL. CLEAN AREA WITH
APPROPRIATE CLEANER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE-KEEP CONTAINER CLOSED UNTIL
READY FOR USE.
Other Precautions:MINIMIZE SKIN CONTACT. WASH WITH SOAP & WATER BEFORE
EATING, DRINKING, SMOKING OR USING TOILET FACILITIES. LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE. PROPERLY DISPOSE OF
CONTAMINATED LEATHER ARTICLES ,INCLUDING SHOES,THAT CANNOT BE
CLEANED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT ORDINARY REQUIRED. USE A NIOSH-APPROVED
RESPIRATOR IF NEEDED.
Ventilation:WORK IN A WELL VENTILATED AREA.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
FORMULA CHANGED. FOR PREVIOUS FORMULATION, SEE P/N A UNDER THE SAME
NSN.
================== Physical/Chemical Properties ==================
HCC:V6
Spec Gravity:0.938
Viscosity:>=100SUS@100F
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER, SEMI-SOLID GREASE - MINERAL OIL ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS HYDROGEN PEROXIDE, BROMINE AND CHROMIC
ACID
Stability Condition to Avoid:HEAT, OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE & DIOXIDE,OXIDES OF
PHOSPHORUS,SULFUR,NITROGEN,CALCIUM,ZINC,HYDROGEN SULFIDE,ALKYL
SULPHIDES,MERCAPTANE
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE IN AN APPROVED DISPOSAL FACILITY OR
DISPOSE OF IN COMPLIANCE WITH ALL LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ALL-STATE 31
CAGE:69482
CAGE:69482
============= Composition/Information on Ingredients =============
Ingred Name:ZINC CHLORIDE (SARA 313) (CERCLA)
CAS:7646-85-7
RTECS #:ZH1400000
Fraction by Wt: <15%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3/2 STEL(FUME)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:LITHIUM FLUORIDE
CAS:7789-24-4
RTECS #:OJ6125000
OSHA PEL:2.5 MG/M3
ACGIH TLV:2.5 MG/M3
Ingred Name:LITHIUM CHLORIDE
CAS:7447-41-8
RTECS #:OJ5950000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POTASSIUM CHLORIDE
CAS:7447-40-7
RTECS #:TS8050000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM CHLORIDE
CAS:7647-14-5
RTECS #:VZ4725000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: SWALLOWING - NAUSEA, VOMITING,
CAN CAUSE CHEMICAL BURN TO DIGESTIVE SYS AND TOXIC EFTS DUE TO
LITHIUM ION. INHAL - IRRITATION TO RESPIRATORY SYS. LITHIUM DUST &
FUMES ARE ABSORBED THRU LUNGS. L UNG DAMAGE. SKIN CONT - DERM,
POSSIBLY CHEM BURN. NOT KNOWN AS SKIN ABSORB. EYE CONT - IRRITATION
TO (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:EYES, & POSSIBLE BURN OF EYE SURFACE.
CHRONIC: COUGH, CNS EFTS, ERYTHEMA, NAUS, KIDNEY EFT. CHRONIC
FLUORIDE ABSORP CAN RSLT IS OSSEOUS FLUOROSIS, INCREASED
RADIOGRAPHIC DENSITY OF BONES & MO TTLING OF TEETH. CHRONIC EXPOS
TO LITHIUM MAY RSLT IN NEUROMUSCULAR EFTS, HYPERACTIVE REFLEXES, &
WT LOSS. (SUPDAT)
Medical Cond Aggravated by Exposure:TARGET ORGANS:SKIN, NASAL, & RESP
IRRITANT, NAUS. CAUSES EYE & SKIN BURNS. PREEXISTING LUNG & SKIN
DISORDERS WILL BE AGGRAVATED.
======================= First Aid Measures =======================
First Aid:INGEST:CALL PHYS/POIS CTL CTR & ADVISE OF HAZ INGRED SECTION.
INHAL:REMOVE TO FRESH AIR. IF FUMES/DUST ARE INHALED, CALL PHYS.
SKIN OR EYE CONTACT:PROMPTLY FLUSH W/WATER FOR @ LST 15 MINS TO
REMOVE AL L RESIDUE. GET MED ATTN FOR EYES. IF RASH DEVELOPS, CALL
PHYS.
===================== Fire Fighting Measures =====================
Extinguishing Media:NOT APPLICABLE. MEDIA SUITABLE FOR SURROUNDING FIRE
.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . METAL HALIDE AND TOXIC FUMES PRODUCED.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:IF A DRY POWDER OR IF MOLTEN, ALLOW TO
SOLIDIFY THEN SWEEP-UP AND DISPOSE TO A CHEMICAL WASTE AREA. FLUSH
AREA WITH WATER TO CHEMICAL SEWER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FLUX DRY. MATERIAL READILY
ABSORBS WATER. KEEP FLUX CONTAINER SEALED.
Other Precautions:REMOVE AND PROFESSIONALLY WASH CONTAMINATED CLOTHING
BEFORE RE-USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF WORK STATION IS NOT VENTILATED TO REMOVE ALL
FUMES AND DUST, USE A NIOSH APPROVED MASK.
Ventilation:MAINTAIN AIR FLOW AWAY FROM USER SO THAT THE TLV IS NEVER
EXCEEDED.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . FULL
PROT EQUIP AS USED IN BRAZE/WEDLING OPERATIONS SO AS TO PVNT ANY
CONT.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING TO REMOVE
ALL RESIDUE.
Supplemental Safety and Health
EFTS OF OVEREXP:MAY BE FATAL IF SWALLOWED/INHALED. SIGNS & SYMPS OF
EXPOS. SWALLOWING:NAUS, VOMIT. INHAL, SKIN & EYE CONT:IRRIT & POSS
CHEM BURNS. DANGER! MAY BE FATAL IF SWALLOWED/INHALED. TOXIC! EYE
PROT:& FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
Spec Gravity:2.15 (H*2O=1)
Solubility in Water:SLIGHT
Appearance and Odor:LIGHT BLUE POWDER; NO CHARACTERISTIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, CYANIDES, AND SULFIDES.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:IF PRESENCE OF WATER AND HEAT, HCL AND
HF WILL BE GIVEN OFF.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL,
STATE, AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: SILVER (HARD, HEAVY BUILD) PLATING SOLUTION, 30308303
Cage: DO645
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 11924
Cage: DO645
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: DANGER! MAY BE FATAL IF SWALLOWED, INHALED, ABSORBED THRU
SKIN. HIGHLY TOX LIQ, VAP, & GAS. CORR LIQS & MIST. CAUSES BURNS. MAY
CAUSE ALLERGIC SKIN RXN. MAY LIBERATE FLAMM GAS. ACUTE:INGEST & INHAL AB
SORPTION THRU SKIN:AVG FATAL DOSE 50-60MG CYANIDE. AMTS ABOVE MILD CAUSES
IMMED UNCONSCIOUSNESS, (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ:CONVLS, DEATH W/IN 1-15 MIN. AMTS
NEAR MLD CAUSE DIZZ, RAPID RESP, VOMIT, FLUSHING, HDCH, DROW, DROP IN BLOOD
PRESS, RAPID PULSE, UNCONSCIOUSNESS, CONVLS, (DEATH W/IN 4 HRS POSS).
EYE/SKIN CN TCT:SEVERITY OF ALKALINE CORR EFT ON TISS DEPENDS ON DURATION OF
CNTCT. CHRONIC:DIZZ, WEAK, LOSS OF APPETITE, (SUPDAT)
Medical Cond Aggravated By Exposure: PREEXISTING RESPIRATORY, CEREBROVASCULAR,
CENTRAL NERVOUS SYSTEM CONDITIONS; LIVER OR KIDNEY DISORDERS; DERMATITIS,
SENSITIZATION TO AMINES.
First Aid: FIRST AIDERS MUST TAKE PROPER PREC FOR THEIR OWN SAFETY BEFORE
ENTERING CONTAMD AREAS TO ASSIST CHEM ACCIDENT VICTIMS & HNDLG THEIR
CONTAMD CLTHG & EQUIP. ALWAYS, HAVE ANOTHER PERS IMMED CALL YOUR EME R
MED SERVICE, POIS CTL CTR, 911-OPERATOR, HOSPITAL, MD/OPHTHALMOLOGIST AS
DESCRIPTION OF ACCIDENT, NAME OF
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: NOTIFY YOUR FACILITY EMER COORDINATOR. DO NOT RELS
INTO SOIL, SEWER, STREAM, POND/SOURCES OF DRINKING H*2O. PROVIDE MAX VEN.
ELIM ALL SOURCES OF IGNIT. WEAR PRESCRIBED PERS PROT EQUIP. ABSORB SMALL SP
ILL ON PAPER TOWELS, PLACE IN DISH IN
Neutralizing Agent: SODIUM OR CALCIUM HYPOCHLORITE AT PH 8.5-10.
Waste Disposal Methods: COLLECT IN TIGHTLY CLOSED PLASTIC CONTAINER. SHIP TO
APPROVED TREATMENT/DISPOSAL FACILITY OR COMMERCIAL PRECIOUS METAL REFINER.
DISPOSE OF ACCORDING TO LOCAL, STATE AND FEDERAL REGULATIONS.
Handling And Storage Precautions: USE "BUDDY SYSTEM" WHEN WORKING WITH
CHEMICALS. DO NOT GET IN EYES, ON SKIN, ON CLOTHING. DO NOT BREATH DUST,
MIST, GAS, USE ONLY WITH ADEQUATE VENT.
Other Precautions: KEEP CNTNR TIGHTLY CLSD IN UPRIGHT POSITION. KEEP AWAY FROM
HEAT, SPARKS, & FLAME. STORE AT 50-90F AWAY FROM INCOMPAT MATLS. PROTECT
CNTNRS AGAINST SPILLAGE & PHYSICAL INJURY. TRIPLE RINSE CNTNR CLEAN
BEFORE DISCARDING.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONE
Lower Limits: NONE
Upper Limits: NONE
Extinguishing Media: ALCOHOL FOAM, ALKALINE DRY CHEMICAL. DO NOT USE CO*2,
WATER, WATER FOAM.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). DO NOT FLUSH INTO SEWER OR STREAM.
Unusual Fire/Explosion Hazard: EXCESSIVE HEAT MAY CAUSE CONTAINERS TO BURST.
THERMAL DECOMPOSITION, ACIDIC WATER OR STEAM MAY LIBERATE HIGHLY TOXIC AND
FLAMMABLE HYDROGEN CYANIDE GAS.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH APPROVED FOR CYANIDE OR SELF-CONTAINED BREATHING
APPARATUS.
Ventilation: LOCAL EXHAUST REQUIRED TO MEET PERMISSIBLE EXPOSURE LIMITS.
Other Protective Equipment: ANSI APPRVD EMER EYE WASH & DELUGE SHOWER (FP N).
IMPERVIOUS BOOTS, APRON, PROT CLTHG AS REQUIRED BY JOB CONDITIONS.
Work Hygienic Practices: WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health: USERS OF "L" VERSION OF SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). SPEC GRAV: 1.107-1.117 (H*2O=1) EFTS OF
OVEREXP: WEIGHT LOSS, MENTAL DETERIORATION, THYROID INSUFFICIENCY, NAUSEA,
RASH, IRRIT OF UPPER RESP TRACT & EYES. MAY CAUSE SENSIT LEADING TO
ASTHMA, ALLERGIC DERM. REMOVE FROM EXPOSURE.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >212F,>100C
M.P/F.P Text: <32F,<0C
Decomp Text: 68.0F,20.0C
Spec Gravity: SUPDAT
PH: 11-12
Evaporation Rate & Reference: SLOWER (ETHYL ETHER = 1)
Solubility in Water: COMPLETE
Appearance and Odor: COLORLESS TO LIGHT YELLOW LIQUID. BITTER ALMONDS ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: CONTACT WITH CO*2 IN AIR GENERATES HCN-GAS.
Materials To Avoid: HEAT, STEAM, ACIDS, ACID FUMES, OXIDIZERS, NITRATES,
NITRITES, FLUORIDES, PEROXIDES, MAGNESIUM.
Hazardous Decomposition Products: HCN, CO*X, NO*X, AG.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: SILVER (HARD, HEAVY BUILD) PLATING SOLUTION, 30308303
Cage: DO645
Assigned IND: Y
Company Name: SIFCO SELECTIVE PLATING, DIV OF SIFCO INDUSTRIES INC
Street: 5708 SCHAAF ROAD
Zipcode: 44131-1394
Label Required IND: Y
Date Of Label Review: 06/11/1997
Status Code: C
Label Date: 06/11/1997
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Severe
Contact Hazard: Severe
Fire Hazard: None
Reactivity Hazard: Slight
Hazard And Precautions: DECOMPOSITION MAY BE HAZARDOUS. ACUTE: FATAL, HIGHLY
TOXIC. CORROSIVE BURNS. ALLERGIC SKIN REACTION. UNCONSCIOUSNESS, CONVULSIONS,
DEATH, DIZZINESS, RAPID RESPIRATION, VOMITING, FLUSHING, HEADACHE, DR
OWSINESS, DROP IN BLOOD PRESSURE, RAPIDPULSE, UNCONSCIOUSNESS, CONVULSIONS.
EYE/SKIN: CORROSIVE. CHRONIC: DIZZINESS, WEAKNESS, LOSS OF APPETITE, WEIGHT
LOSS, RASH, IRRITATION, SENSITIZATION OF RESPIRA TORY SYSTEM AND SKIN.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PT-426 #16440
Kit Part:Y
CAGE:06341
CAGE:06341
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM(TYPE 3)
RTECS #:XR1702000
Fraction by Wt: 27%
Ingred Name:N-BUTYL ALCOHOL
RTECS #:EO1575000
Fraction by Wt: 8%
ACGIH TLV:1900 PPM
Ingred Name:ETHYLENE GLYCOL ETHYL ETHER
RTECS #:KW5950000
Fraction by Wt: 8%
ACGIH TLV:200 PPM
Ingred Name:YELLOW IRON OXIDE
Fraction by Wt: 0.12%
Ingred Name:CARBON BLACK
RTECS #:FF5868000
===================== Hazards Identification =====================
Effects of Overexposure:THE SOLVENT IS IRRITATING TO EYES,IS NOT
SIGNIFICANT IRRIT TO SKN UNLSS EXPOSR PROLNG/FREQUENTLY REP
======================= First Aid Measures =======================
First Aid:SKIN CONTACT:WASH WITH SOAP & WATER. EYE CONTACT WASH WITH
PLENTY OF WATER & CONSULT AN EYE PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:99F TOC 37C
Lower Limits:1.45
Upper Limits:11.2
Extinguishing Media:USE FOAM & DRY CHEMICALS.
Fire Fighting Procedures:FIGHT AS A SOLVENT FIRE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/ABSORBING COMPOUND & DISCARD.
======================Handling and Storage ======================
Handling and Storage Precautions:THIS PRODUCT SHOULD BE KEPT IN CLOSED
CONTAINERS IN COOL DRY AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATORS EFFECTIVE F/ORGANIC SOLVENTS.
Ventilation:MECHANICAL-NEEDED
Supplemental Safety and Health
KEY1:F4
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:275.9
Vapor Pres:5.3
Spec Gravity:9.65
Evaporation Rate & Reference:N-BUTYL AC
Solubility in Water:MODERATE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:SHOULD BE IN ACCORDANCE W/FEDERAL, STATE, & LOC
ENVIRONMENTAL CONTROL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SODIUM BORATE DECAHYDRATE
CAGE:63415
CAGE:60777
CAGE:63415
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM TETRABORATE, DECAHYDRATE
CAS:1303-96-4
RTECS #:VZ2275000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3
ACGIH TLV:5 MG/M3; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RAT LD50: 2660 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE EYE, SKIN & RESPIRATORY
TRACT IRRITATION. INGESTION MAY CAUSE CNS DEPRESSION OR KIDNEY
FAILURE. PROLONGED OR REPEATED OVEREXPOSURE MAY CAUSE BRONCHITIS,
LARYNGITIS, WEIGHT LOSS, SKIN RASH OR DERMATITIS, BALDNESS,
ANEMIA, CONJUNCTIVITIS, KIDNEY AND LIVER DAMAGE.
Explanation of Carcinogenicity:THIS PRODUCT IS NOT LISTED BY IARC, NTP
OR OSHA AS A CARCINOGEN, MUTAGEN, TERATOGEN OR NEUROTOXIN.
Effects of Overexposure:MAY CAUSE EYE, SKIN & RESPIRATORY TRACT
IRRITATION. MAY CAUSE FEVER, NAUSEA, VOMITING, DIARRHEA,
CONVULSIONS, JAUNDICE, WEIGHT LOSS, SKIN RASH OR DERMATITIS,
CONJUNCTIVITIS, WEAKNESS, LETHARGY, HEADAC HE, INSOMNIA,
RESTLESSNESS, TREMORS ANDTWITCHING OF FACIAL MUSCLES AND
EXTREMITIES, CONFUSION, DROWSINESS AND SHOCK.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE KIDNEYS OR LIVER MAY
BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRATION. GET MEDICAL ATTENTION. EYES: IMMEDIATELY
FLUSH WITH RUNNING WATER FOR 15 MINUTES. GET MEDICAL ATTENTION.
SKIN: WASH WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. IF
IRRITATION DEVELOPS, GET MEDICAL ATTENTION. INGESTION: IF
CONSCIOUS, GIVE GLASS OF WATER TO DRINK AND INDUCE VOMITING. GET
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:NONE
Extinguishing Media:USE EXTINGUISHING AGENT SUITABLE FOR TYPE OF
SURROUNDING FIRE.
Fire Fighting Procedures:MOVE CONTAINER FROM FIRE AREA IF POSSIBLE.
AVOID BREATHING VAPORS OR DUSTS; KEEP UPWIND.
Unusual Fire/Explosion Hazard:WHEN EXPOSED TO FIRE, MATERIAL MAY MELT
TO A GLASSY MATERIAL WHICH CAN FLOW IN LARGE QUANTITIES AND IGNITE
SURROUNDING COMBUSTIBLE MATERIALS.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP AND PLACE IN SUITABLE CLEAN, DRY
CONTAINERS FOR RECLAMATION OR LATER DISPOSAL. DO NOT FLUSH WITH
WATER. KEEP UNNECESSARY PEOPLE AWAY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE; KEEP
CONTAINER TIGHTLY CLOSED WHEN NOT IN USE.
Other Precautions:TARGET EFFECTS: CENTRAL NERVOUS SYSTEM DEPRESSANT;
NEPHROTOXIN. POISONING MAY ALSO AFFECT THE LIVER AND
GASTROINTESTINAL SYSTEM.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:THE SPECIFIC RESPIRATOR SELECTED MUST BE BASED
ON CONTAMINATION LEVELS FOUND IN THE WORK PLACE, MUST NOT EXCEED
THE WORKING LIMITS OF THE RESPIRATOR AND BE JOINTLY APPROVED BY
NIOSH & MSHA. AS A MINIM IUM, A DUST & MIST WITH FULL FACEPIECE.
Ventilation:LOCAL AND MECHANICAL(GENERAL) EXHAUST TO PROVIDE ADEQUATE
VENTILATION.
Other Protective Equipment:WEAR IMPERVIOUS INDUSTRIAL WORK CLOTHING.
HAVE EMERGENCY EYE WASH AND SAFETY SHOWER AVAILABLE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING, DRINKING OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE DUST. DO NOT INGEST. READ PRECAUTIONS ON LABEL BEFORE
USE.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:608F,320C
Melt/Freeze Pt:M.P/F.P Text:167F,75C
Decomp Temp:Decomp Text:212F,100C
Vapor Density:13.1
Spec Gravity:1.73
pH:9.5
Solubility in Water:MODERATE
Appearance and Odor:ODORLESS, HARD CRYSTALS, GRANULES OR CRYATALINE
POWDER WITH A WHITE COATING.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ZIRCONIUM: EXPLOSIVE REACTION WHEN HEATED.
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE TOXIC SODIUM OXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:OBSERVE ALL LOCAL, STATE AND FEDERAL REGULATIONS
WHEN STORING OR DISPOSING OF THIS SUBSTANCE. FOR ASSISTANCE,
CONTACT THE DISTRICT DIRECTOR OF THE ENVIRONMENTAL PROTECTION
AGENCY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PERMA-LOK LM 113, 78-4311
Preparer's Name:PHILIP A. TOSCANO
CAGE:85091
CAGE:85091
============= Composition/Information on Ingredients =============
Ingred Name:METHACRYLIC ACID, 2-HYDROXYETHYL ESTER; (HYDROXYETHYL
METHACRYLATE). LD50:(ORAL,RAT) 1250 MG/KG.
CAS:868-77-9
RTECS #:OZ4725000
Fraction by Wt: >1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:HYDROPEROXIDE, ALPHA, ALPHA-DIMETHYLBENZYL-; (CUMENE
HYDROPEROXIDE) (SARA 313) (CERCLA). LD50:(ORAL,RAT) 800 MG/KG.
CAS:80-15-9
RTECS #:MX2450000
Fraction by Wt: >1%
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:VOLATILE ORGANIC COMPOUNDS: 0.09 LBS/GAL (10 G/L).
RTECS #:9999999VO
Ingred Name:SUPDAT:CORR. CAN CAUSE PERM SKIN DMG. SKIN SENSITIZER.
INHAL TOX:CAN CAUSE SEV IRRIT & SENSIT. PRLNG EXPOS CAN (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:CAUSE LUNG DMG. EXCESSIVE EXPOS MAY CAUSE HDCH &
OTHER NERV SYS EFTS. CAN CAUSE PERM EYE DMG. HAS CAUSED (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:LIVER, KIDNEY & BLOOD EFFECTS IN LAB ANIMALS.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:MILK/WATER TO DILUTE STOM CONTENTS. KEEP
WARM & QUIET. GET PROMPT MED ATTN. DO NOT ATTEMPT TO GIVE(ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:PRESS. VENT DISP CNTNR TO PVNT BUILDUP OF PRESS.
CAN CAREFULLY SOLIDIFY W/ANAEROBIC SURF CONDITIONER (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:& DISPOSE OF AS SOLID WASTE.
RTECS #:9999999ZZ
Ingred Name:EYE PROT:& FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
Ingred Name:HYGIENE PRACT:CLOTHING & LAUNDER BEFORE REUSE IF
CONTAMINATED W/PRODUCT.
RTECS #:9999999ZZ
Ingred Name:METHACRYLIC ACID, DIESTER WITH TETRAETHYLENE GLYCOL;
(TETRAETHYLENEGLYCOL DIMETHACRYLATE)
CAS:109-17-1
RTECS #:OZ4000000
Fraction by Wt: >1%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE:IRRIT, & MAY INJURE TISS IF
NOT REMOVED PROMPTLY. SKIN:FREQUENT/PRLNG CONT MAY IRRIT & CAUSE
DERM. MAY CAUSE SENSIT, PARTIAL/WHOLE-BODY DERMATITIC RASH EXPER
AFTER EXPOS, HOWEVER MIN. INHAL: BASED ON ITS LOW VOLATILITY, PROD
IS NOT CONSIDERED TO BE RESP HAZ UNDER NORMAL CNDTNS OF USE. IRRIT
&/(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:OR TOX VAPS MAY BE RELS AT ELEVATED
TEMPS. INGEST:EFTS HAVE NOT BEEN EVALUATED BUT ARE ASSUMED TO CAUSE
NAUS & VOMIT. CHRONIC:IN CERTAIN INDIVIDUALS, SENSIT MAY OCCUR
CAUSING DERM W/EVEN MIN CONT. DUE TO SKIN ABSORB W/EXCESSIVE CONT,
PROD MAY PRDCE NERV SYS EFTS, I.E., ATAXIA. TARGET ORGS:SKIN; EYES.
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:IMMED FLUSH W/LG AMTS OF WATER FOR AT LST 15 MINS,
LIFTING UPPER & LOWER LIDS. GET PROMPT MED ATTN. SKIN:FLUSH EXPOS
AREAS THORO W/SOAP & WATER UNTIL ALL CHEM IS REMOVED. REMOVE CONTAM
CLTHG & LAU NDER BEFORE REUSE. INHAL:REMOVE TO FRESH AIR. IF BRTHG
IS DFCLT, GIVE OXYG. IF BRTHG HAS STOPPED, GIVE ARTF RESP. GET MED
ATTN. INGEST:DO NOT INDUCE VOMIT. IF INDIVIDUAL IS CONSCIOUS, GIVE
(ING 8)
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:230F,110C
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . COOL EXPOSED EQUIPMENT W/WATER SPRAY.
Unusual Fire/Explosion Hazard:POLYMERIZATION MAY TAKE PLACE AT ELEVATED
TEMPERATURES.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROT CLTHG. STOP LEAK IF YOU CAN DO IT
W/OUT RISK. FOR SM SPILLS TAKE UP W/SAND OR OTHER INERT ABSORB MATL
& PLACE IN CNTNR FOR LATER DISP. NOTE:IN BULK QTYS, PROD ABSORBED
ON INERT MATL MAY POLY MERIZE GENERATING SIGNIFICANT HEAT & (ING
10)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMP. AVOID EXCESSIVE
HEAT. STORE OUT OF DIRECT SUNLIGHT IN DRY AREA. MAXIMUM STORAGE
TEMP IS 100F.
Other Precautions:CONDITIONS UNDER WHICH PERSONAL PROTECTIVE EQUIPMENT
REQUIRED:NORMAL WORK CONDITIONS; SPILL/CLEANUP; MAINTENANCE/REPAIR.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL HANDLING CONDITIONS.
USE NIOSH/MSHA APPROVED RESPIRATOR IF VAPOR OR MIST LEVELS ARE
IRRITATING.
Ventilation:GENERAL.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . NO SPECIAL CLTHG REQD FOR LOW VOL ACTIVITY.
Work Hygienic Practices:WASH HANDS W/SOAP & WATER IF CONT W/PROD
OCCURS/BEFORE EATING, DRINKING, SMOKING/USING TOILET FACILITIES.
REMOVE(ING 13)
Supplemental Safety and Health
CNDTNS(POLYM):ANAEROBIC SURF CONDITIONER IN LG QTYS, WILL ALSO CAUSE
POLYMERIZATION. EFTS OF OVEREXP:TOX INFO:ING 1:SKIN & EYE IRRIT &
SKIN SENSITIZER. ING 2:SLIGHT SKIN IRRIT. HIGH VAP CONCS MAY IRRI T
RESP TRACT. WILL CAUSE SEV EYE IRRIT.ING 3:ORAL TOX:CORR TO MOUTH,
ESOPHAGUS & STOM. HIGHLY TOX. DERMAL TOX: (ING 5)
================== Physical/Chemical Properties ==================
Vapor Pres:0.01 @ 77F
Vapor Density:1.01
Spec Gravity:1.07 (H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:PURPLE LIQUID; MILD PLEASANT ODOR.
Percent Volatiles by Volume:<1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
METALS & THEIR SALTS, PERMA-LOK (R) ANAEROBIC SURFACE CONDITIONERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:THERMAL DECOMPOSITION COULD PRODUCE
CARBON MONOXIDE, CARBON DIOXIDE & UNIDENTIFIED ORGANIC COMPOUNDS.
Conditions to Avoid Polymerization:PERMA-LOK(R) PRODS ARE ANAEROBIC &
POLYMERIZE IN ABSENCE OF AIR. SUNLIGHT, EXCESSIVE HEAT & CONTAM BY
METALS/ (SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE DISPOSAL SHOULD BE I/A/W EXISTING FEDERAL,
STATE & LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:D-233 DESMODUR W
Preparer's Name:B J GAMBINO
CAGE:EO419
CAGE:19511
CAGE:EO419
============= Composition/Information on Ingredients =============
Ingred Name:METHYLENE BIS(4-CYCLOHEXYLISOCYANATE)
CAS:5124-30-1
RTECS #:NQ9250000
Fraction by Wt: 100%
Other REC Limits:0.005 PPM
OSHA PEL:0.01 PPM
ACGIH TLV:0.054 MG/CUM
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): >11,000 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY TRACT MUCOUS
MEMBRANES IRRITATION. BRONCHITIS/BRONCHIAL SPASM/PULMONARY EDEMA.
CHEMICAL/HYPERSENSITIVE PNEUMONITIS W/FLU EFFECTS.SKIN:
IRRITATION/SENSITIZATION. EYES: IRRITAT
ION/TEARING/REDNESS/SWELLING/STINGING SENSATION. INGESTION:
IRRITATION/CORROSIVE TO MOUTH/STOMACH TISSUE/DIGESTIVE TRACT
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: ISOCYANATE SENSITIZATION. LUNG
DAMAGE, INCLUDING DECREASE IN LUNG FUNCTION. SKIN: REDDENING,
SWELLING, RASH , SCALING OR BLISTERING.
Medical Cond Aggravated by Exposure:SKIN ALLERGIES, ASTHMA & ANY OTHER
RESPIRATORY DISORDERS, ECZEMA.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LUKEWARM WATER FOR 15 MINS. SKIN: WASH W/SOAP &
WATER. FOR SEVERE EXPOSURES, GET UNDER SAFETY SHOWER AFTER REMOVING
CLOTHING. INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN/ARTIFICIAL
RESP IRATION. TREATMENT IS SYMPTOMATIC. INGESTION: DON'T INDUCE
VOMITING. GIVE 1-2 CUPS OF MILK/WATER TO DRINK. DON'T GIVE ANYTHING
BY MOUTH TO AN UNCONSCIOUS/CONVULSING PERSON. OBTAIN MED ATTN. SEE
SUPP.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>395F/202C
Extinguishing Media:DRY CHEMICAL, COW, FOAM, WATER SPRAY FOR LARGE
FIRES.
Fire Fighting Procedures:FULL EMERGENCY EQUIPMENT W/SCBA & FULL
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:CLOSED CONTAINER MAY EXPLODE WHEN EXPOSED
TO EXTREME HEAT OR BURST WHEN CONTAMINATED W/WATER (CO2 EVOLVED).
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE/VENTILATE AREA. DIKE/IMPOUND/CONTROL
FURTHER SPILL. COVER W/ABSORBENT MATERIAL. POUR DECONTAMINATION
SOLUTION OVER SPILL & ALLOW TO REACT FOR 10 MINS. COLLECT IN
CONTAINERS & ADD MORE SOLUTIO N. REMOVE/COVER LOOSELY/ALLOW TO
STAND 24-48 HRS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN TIGHTLY CLOSED CONTAINERS TO
PREVENT MOISTURE CONTAMINATION. DON'T RESEAL CONTAINER IF
CONTAMINATION IS SUSPECTED. STORE AT 68-81F.
Other Precautions:AVOID CONTACT W/SKIN, EYES & BREATHING OF VAPORS.
DON'T WEAR CONTACT LENSES. SHELF LIFE: 12 MONTHS. PRODUCT REACTS
SLOWLY W/WATER TO FORM CO2. THIS GAS CAN CAUSE SEALED CONTAINERS TO
EXPAND & POSSIBLY RUPTURE EXPLOSIVELY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A POSITIVE PRESSURE SUPPLIED AIR RESPIRATOR
IF THE AIRBORNE ISOCYANATE CONCENTRATIONS ARE NOT KNOWN OR EXCEED
0.005 PPM, OR IF OPERATIONS ARE PERFORMED IN A CONFINED SPACE OR
AREA W/LIMITED VENTIL ATION; OR WHERE MATERIAL IS HEATED.
Ventilation:SUFFICIENT LOCAL EXHAUST TO KEEP BELOW TLV
Other Protective Equipment:FULL ACID SUIT, OVERSHOES, FULL PERMEATION
RESISTANT PROTECTIVE SUIT. SAFETY SHOWERS, EYEWASH STATIONS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. EDUCATE & TRAIN EMPLOYEES IN SAFE USE & FOLLOW LABEL
INSTRUCTIONS.
Supplemental Safety and Health
NOTE TO PHYSICIAN: EYES: STAIN FOR EVIDENCE OF CORNEAL INJURY, IF
BURNED, INSTILL ANTIBIOTIC/STEROID PREPARATION FREQUENTLY. SKIN:
TREAT SYMPTOMATICALLY. INGESTION: TREAT SYMPTOMATICALLY. NO
SPECIFIC ANTIDOTE. INHALATION: REMOVE TO FRESH AIR, IF A PERSON IS
HAVING A DERMAL OR PULMONARY SENSITIZATION REACTION.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:DECOMPOSES
Vapor Pres:0.001
Spec Gravity:1.07
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR, ODORLESS LIQUID
Percent Volatiles by Volume:NEGL.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, AMINES, STRONG BASES, ALCOHOLS, METALS COMPOUNDS & SURFACE
ACTIVE MATERIALS.
Stability Condition to Avoid:EXTREME HEAT, MOISTURE
Hazardous Decomposition Products:CO2, CO, OXIDES OF NITROGEN, TRACES OF
NITROGEN CYANIDE
Conditions to Avoid Polymerization:MOISTURE OR OTHER MATERIALS WHICH
REACT W/ISOCYANATES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. HANDLE EMPTY CONTAINERS W/CARE DUE TO PRODUCT
RESIDUE. DECONTAMINATE CONTAINERS PRIOR TO DISPOSAL. DON'T HEAT OR
CUT EMPTY CONTAINER W/E LECTRIC OR GAS TORCH. POISONOUS
LIQUID.UN2810.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:IMP X HDO 30, S-330
CAGE:DO955
CAGE:58563
CAGE:DO955
============= Composition/Information on Ingredients =============
Ingred Name:ADDITIVES, <1% OF GAL
===================== Fire Fighting Measures =====================
Flash Point:230C
Extinguishing Media:CARBON DIOXIDE, WATER FOG, FOAM, DRY CHEM
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SELF-CNTND BRTHNG
APPARATUS
Unusual Fire/Explosion Hazard:NONE, USE WATER SPRAY TO COOL FIRE
EXPOSED CNTNRS
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE & CONTAIN SPILL W/INERT MATL:
SAND,EARTH,FULLERS EARTH,ETC. TRANSFER LIQ DIKING MATL TO SEPERATE
CNTNRS FOR RECOVERY OR DISPOSAL. AREA MAY BE SLIPPERY. CARE SHOULD
BE TAKEN TO AVOID FALLS. PREVEN T MATL FROM GETTING INTO SEWERS &
OPEN WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:THESE LUBRICANTS BECOME VERY VISCOUS
WHEN STORED AT LOW TEMPS. THEY CONGEAL AT TEMPS FROM -12 TO -32C.
============= Exposure Controls/Personal Protection =============
Other Protective Equipment:EYEWASH FACILITY
Supplemental Safety and Health
VAP PRESS <1MM. VAP DNSTY <1. SPEC GRAV <1.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:>600F
Evaporation Rate & Reference:<1 BUTYL ACETATE
Appearance and Odor:DARK AMBER, NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:WHEN BURNING: CARBON MONOXIDE, CARBON
DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE LIQ IN APPRVD EQUIP. LANDFILL CONTAM
DIKING MATL TO CURRENT LOCAL, STATE, FED REG.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:4914 MAGNESIUM SULFATE INJECTION USP
CAGE:60060
CAGE:60060
============= Composition/Information on Ingredients =============
Ingred Name:MAGNESIUM SULFATE HEPTAHYDRATE
CAS:10034-99-8
RTECS #:OM4508000
Ingred Name:DEXTROSE
CAS:50-99-7
RTECS #:LZ6600000
= Wt:5.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Health Hazards Acute and Chronic:THIS MATERIAL IS USED AS AN
ANTICONVULSANT. INGESTION: CAN RESULT IN A LAXATIVE EFFECT. MAY
AFFECT THE GASTROINTESTINAL TRACT, NERVOUS SYSTEM, CARDIOVASCULAR
SYSTEM & HEART. ADMINISTRATION TO PREGNANTWOMEN PRIOR TO DELIVERY
CAN RESULT IN HYPOTENSION, HYPOREFLEXIA, HYPOTENIA & RESPIRATORY
DEPRESSION IN THE NEONATE.
Effects of Overexposure:NAUSEA, VOMITING, ABDOMINAL PAIN, DIARRHEA,
ELECTROLYTE LOSS, SEDATION, FLUSHING, SWEATING, HYPOTENSION,
HYPOTHERMIA, REDUCED RESPIRATION RATE, HYPOTONIA, DEPRESSED
REFLEXES, REDUCED HEART RATE, ALTER ED ECG & CIRCULATORY COLLAPSE.
Medical Cond Aggravated by Exposure:HEART BLOCK, MYOCARDIAL DAMAGE,
MAGNESIUM INTOXICATION, AILMENTS OF RESPIRATORY, RENAL & GI.
CONCURRENT USE OF NERVOUS SYSTEM DEPRESSANT, NEUROMUSCULAR BLOCKING
DRUGS & CARDIAC GLYCOSIDE.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: REMOVE FROM SOURCE OF EXPOSURE. FLUSH W/COPIOUS
AMOUNTS OF WATER. INGESTION: INDUCE EMESIS/PERFORM GASTRIC LAVAGE
IF PATIENT IS ALERT. INTRAVENOUS CALCIUM GLUCONATE CAN COUNTERACT
THE EFFEC TS OF HYPERMAGNESEMIA. PROVIDE SYMPTOMATIC/SUPPORTIVE
CARE, MONITOR CARDIOVASCULAR & RESPIRATORY.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA APPROPRIATE FOR PRIMARY CAUSE OF FIRE.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS, FLAME
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/SUITABLE MATERIAL & PLACE INTO
CONTAINER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE 77F. AVOID
EXCESSIVE HEAT. PROTECT FROM FREEZING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NEEDED DURING NORMAL PRODUCT USE.
Ventilation:NO SPECIAL PROVISIONS REQUIRED UNDER NORMAL PRODUCT USE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:WATER SOLUBLE
Appearance and Odor:CLEAR ODORLESS SOLUTION
================= Stability and Reactivity Data =================
Stability Condition to Avoid:EXCESSIVE HEAT, FREEZING
Hazardous Decomposition Products:BY HEATING: TOXIC FUMES OF SULFUR
OXIDES
=================== Toxicological Information===================
Toxicological Information:IN CLINICAL USE, MAGNESIUM SULFATE IS USED
ORALLY AS A LAXATIVE & IS GIVEN BY INJECTION TO TREAT CONVULSIONS &
MAGNESIUM DEFICIENCY. IT ACTS TO DEPRESS THE NERVOUS SYSTEM &
ALTERS CARDIAC & CARDIOVASC ULAR FUNCTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:NOT REGULATED.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BRAYCO 443
CAGE:EO288
CAGE:EO288
DIV
CAGE:2R128
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE EYE IRRITATION. PROLONGED OR
REPEATED SKIN CONTACT MAY CAUSE SKIN IRRITATION, DEFATTING.
EXCESSIVE INHALATION OF VAPOR MAY CAUSE NASAL/RESPIRATORY
IRRITATION, DIZZINESS. INGESTION CAN CAUSEGASTROINTESTINAL
IRRITATION, NAUSEA, VOMITING, DIARRHEA.
Explanation of Carcinogenicity:PRODUCT CONTAINS NO MATERIALS CURRENTLY
CLASSIFIED AS CARCINOGENIC BY NTP, IARC OR OSHA.
Effects of Overexposure:--EYE IRRITATION, REDNESS, TEARING, BLURRED
VISION. --SKIN IRRITATION, DEFATTING, DERMATITIS.
--RESPIRATORY/NASAL IRRITATION, DIZZINESS, NAUSEA, HEADCAHE;
POSSIBLY UNCONSCIIOUSNESS, ASPHYXIATION.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:SKIN-REMOVE CONTAMINATED CLOTHING. WIPE MATERIAL FROM SKIN.
WASH THOROUGHLY WITH SOAP & WATER. EYE-FLUSH EYES WITH LARGE
AMOUNTS OF CLEAN WATER FOR AT LEAST 15 MIN. CONTACT A PJYSICIAN IF
IRRITATION P ERSISTS. INGESTION-DO NOT INDUCE VOMTING; ASPIRATION
HAZARD. CONSULT A PHYSICIAN IMMEDIATELY. INHALATION-REMOVE FROM
AREA OF EXPOSURE. ADMINISTER OXYGEN. IF BREATHING STOPS, GIVE CPR.
CONTACT PHYSICAN
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:400F,204C
Autoignition Temp:Autoignition Temp Text:NA
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, FOAM.
Fire Fighting Procedures:USE WATER AS FOG OR SPRAY TO COOL FIRE EXPOSED
CONTAINERS. WEAR SELF-CONTAINED BREATHING APPARATUS IN POSITIVE
PRESSURE MODE IN CONFINED AREAS.
Unusual Fire/Explosion Hazard:EMPTY CONTAINERS MAY RETAIN PRODUCT
RESIDUE OR VAPOR WHICH CAN IGNITE EXPLOSIVELY; DO NOT CUT, DRILL OR
WELD ON OR NEAR FULL OR EMPTY CONTAINERS.
================== Accidental Release Measures ==================
Spill Release Procedures:DO NOT PERMIT PRODUCT TO ENTER STREAMS, SEWERS
OR OTHER SOURCE WATERWAYS. DIKE SPILL AND ELIMINATE LEAK. ABSORB
WITH INERT MATERIAL AND STORE IN CLOSED CONTAINERS UNTIL DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:MAINTAIN AMBIENT TEMPERATURES. AVOID
PROLONGED/REPEATED BREATHING OF VAPORS, MISTS, FUMES. KEEP
CONTAINER TIGHTLY CLOSED.
Other Precautions:DO NOT STORE NEAR HEAT, FLAME, STRONG OXIDANTS.
MAINTAIN ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA-APPROVED ORGANIC VAPOR RESPIRATOR OR
SUPPLIED AIR RESPIRATORY EQUIPMENT AS REQUIRED.
Ventilation:PROVIDE SUFFICIENT MECHANICAL, GENERAL &/OR LOCAL EXHAUST
TO MAINTAIN EXPOSURE BELOW TLV. >THAN 60F3/MIN RECOMMENDED.
Other Protective Equipment:IMPERVIOUS GARMETS AS REQUIRED.
Work Hygienic Practices:DO NOT WEAR CONTAMINATED CLOTHING. LAUNDER
BEFORE REUSE OR DISCARD. WASH THOROUGHLY AFTER USE.
Supplemental Safety and Health
DO NOT TAKE ANY FOOD OR DRINK, OR HANDLE TOBACCO PRODUCTS WHILE IN
CONTACT WITH THIS PRODUCT.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:>500F,>260C
Melt/Freeze Pt:M.P/F.P Text:ND
Decomp Temp:Decomp Text:ND
Vapor Pres:<0.01 MMHG
Vapor Density:>1
Spec Gravity:0.90
pH:ND
Viscosity:ND
Evaporation Rate & Reference:<0.01
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR AMBER LIQUID. SLIGHT HYDROCARBON ODOR.
Percent Volatiles by Volume:NA
Corrosion Rate:NA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, OPEN FLAMES.
Hazardous Decomposition Products:SMOKE, FUMES, CARBON MONOXIDE, CARBON
DIOXIDE; MINOR AMOUNTS OF VARIOUS HYDROCARBONS AND OXIDES OF
NITROGEN, SULFUR, ETC
==================== Disposal Considerations ====================
Waste Disposal Methods:ALL RECOVERED MATERIAL SHOULD BE PACKAGED,
LABELLED, TRANSPORTED & DISPOSED OF OR RECLAIMED IN ACCORDANCE WITH
GOOD ENGINEERING PRACTICES. DISPOSE OF BY METHODS IN COMPLIANCE
WITH LOCAL, STATE AND FED ERAL REGULATIONS. MAY BE DESTROYED BY
INCINERATION
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:4070 SPRED-ULTRA FLAT LATEX WALL & TRIM PAINT
CAGE:01PD6
CAGE:72818
CAGE:01PD6
============= Composition/Information on Ingredients =============
Ingred Name:KAOLIN
CAS:1332-58-7
RTECS #:GF1670500
Fraction by Wt: 10-15%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9293
Ingred Name:ETHYLENE GLYCOL (SARA III)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 1-5%
Other REC Limits:10 MG/CUM
OSHA PEL:C 50 PPM
ACGIH TLV:C 50 PPM,VAPOR; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICON DIOXIDE
CAS:7631-86-9
RTECS #:VV3100000
Fraction by Wt: 2-7%
OSHA PEL:80 MG/CUM
ACGIH TLV:0.1 MG/CUM
Ingred Name:SODIUM ALUMINOSILICATE
CAS:1344-00-9
Fraction by Wt: 1-5%
ACGIH TLV:10 MG/CUM
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 15-20%
Other REC Limits:NUISANCE PARTICULATE
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:VINYL ACRYLIC RESIN
CAS:25067-01-0
Fraction by Wt: 8-13%
Ingred Name:WATER, H2O
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 44-49%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: MUCOUS MEMBRANE
IRRITATION, DROWSINESS, DIZZINESS, LIGHTHEADEDNESS, & HEADACHE.
SKIN/EYES: IRRITATION. INGESTION: LARGE AMOUNTS COULD CAUSE SERIOUS
INJURY, ADVERSE HEALTH EFFECTS, KIDNEY D AMAGE OR FAILURE.
Explanation of Carcinogenicity:CRYSTALLINE SILICA IS A SUSPECTED HUMAN
CARCINOGEN.
Effects of Overexposure:INHALATION: MUCOUS MEMBRANE IRRITATION,
DROWSINESS, DIZZINESS, LIGHTHEADEDNESS, & HEADACHE. SKIN/EYES:
IRRITATION. INGESTION: LARGE AMOUNTS COULD CAUSE SERIOUS INJURY,
ADVERSE HEALTH EFFECTS, KIDNEY D AMAGE OR FAILURE.
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN,
RESPIRATORY, LUNG, & KIDNEY DISORDERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR OR OXYGEN IF
NEEDED. SKIN: WASH W/PLENTY OF WATER, THEN SOAP & WATER. EYES:
FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS. INGESTION: OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:>200F
Extinguishing Media:DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:WATER MAY BE USED TO COOL & PROTECT EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY BURST IF EXPOSED TO
EXTREME HEAT OR FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:COMPLY W/ALL APPLICABLE HEALTH & ENVIRONMENTAL
REGULATIONS. VENTILATE AREA. COLLECT W/ABSORBENT MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE <100F. KEEP FROM FREEZING. USE
ONLY W/ADEQUATE VENTILATION. KEEP CONTAINERS TIGHTLY CLOSED &
UPRIGHT WHEN NOT IN USE. DON'T TAKE INTERNALLY.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID CONTACT W/SKIN,
EYES, & BREATHING VAPORS. IF SANDING IS DONE, WEAR A DUST MASK TO
AVOID BREATHING OF SANDING DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR. WEAR A DUST
MASK, IF SANDING.
Ventilation:PROVIDE MECHANICAL/LOCAL EXHAUST VENTILATION TO PREVENT
BUILD-UP OF VAPORS.
Other Protective Equipment:EYE WASH, SAFETY SHOWER
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS THOROUGHLY AFTER HANDLING, BEFORE EATING, OR
SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text: 212F
Appearance and Odor:LIQUID
Percent Volatiles by Volume:69.1%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS,
Stability Condition to Avoid:ELEVATED TEMPERATURES >100F, FREEZING
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:8800K12
CAGE:KO118
CAGE:15605
CAGE:KO118
============= Composition/Information on Ingredients =============
Ingred Name:RADIUM 226
===================== Hazards Identification =====================
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
======================= First Aid Measures =======================
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
===================== Fire Fighting Measures =====================
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
================== Accidental Release Measures ==================
======================Handling and Storage ======================
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
SOURCE OF DATA-MIL HANDBOOK 600-1 SEP 76.SAFETY & HEALTH DATA DEVELOPED
BY DGSC-STF.
================== Physical/Chemical Properties ==================
HCC:A2
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-IN ACCORDANCE WITH
REGULATIONS AND FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:WM BIRD HERITAGE LATEX WALL PAINT, 5-8500
CAGE:JO286
CAGE:JO286
CAGE:WATTL
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS VP: @ 20C
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: WITH POOR
VENTILATION, VAPOR OR SPRAY MIST MAY IRRITATE RESPIRATORY MUCOUS
MEMBRANES, CAUSING HEADACHE AND NAUSEA. EYE CONTACT: PRIMARY
IRRITANT. CHRONIC: NONE RECOGNIZED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH IMMEDIATELY WITH
LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. TAKE TO PHYSICIAN
FROM MEDICAL TREATMENT. SKIN: REMOVE WITH SOAP AND WATER. IF
DRENCHED, R EMOVE CONTAMINATED CLOTHING. INGESTION:IF VICTIM IS
CONSCIOUS, GIVE 2 GLASSES OF WATER TO DILUTE. DO NOT INDUCE
VOMITING. CONSULT PHYSICIAN OR POISON CONTROL CENTER.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NONE
Extinguishing Media:(APPLICABLE ONLY FOR COOLING CLOSED CONTAINERS.)
WATER FOG.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AS DESCRIBED IN VENTILATION SECTION.
AVOID UNNECESSARY SKIN CONTACT. COLLECT BY ABSORPTION, SHOVEL
AND/OR WET MOPPING.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. CLOSE
CONTAINER AFTER EACH USE. DO NOT TAKE INTERNALLY. OBSERVE GOOD
SANITARY PRACTICES.
Other Precautions:NOTE:PIGMENTED PAINTS & COATING (THOSE WHICH ARE
OPAQUE, COLORED OR WHICH HAVE REDUCED GLOSS WHEN DRY) MAY CONTAIN
MATERIALS SUCH AS SILICA, TALC, CALCIUM CARBONATE, TITANIUM
DIOXIDE, ETC. WHICH ARE H AZ TO INHAL IN THE DRY POWDER (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DURING SPRAY APPLICATION USE NIOSH APPROVED
MECHANICAL FILTER RESPIRATOR TO REMOVE SOLID AIRBORNE PARTICLES OF
OVERSPRAY.
Ventilation:PROVIDE SUFFICIENT VENT, IN VOLUME & PATTERN, TO INSURE
VAPOR CONC WELL BELOW ANY TLV & LEL LISTED IN INGRED SECTION.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
OTHER PREC: FORM. THESE HAZARDS ARE NOT BELIEVED TO BE PRESENT WHEN THE
POWDERS ARE DISPERSED IN LIQUID COATINGS. HOWEVER, PRECAUTIONS IN
SECTION VIII SHOULD BE CAREFULLY OBSERVED AND NIOSH APPROVED R
ESPIRATORS SHOULD ALSO BE USED IF THE DRIED COATING IS SANDED OR
ABRADED IN SUCH A WAY AS TO PRODUCE DUST.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:SEE INGRED
Vapor Density:LTR/AIR
Spec Gravity:1.32-1.39
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:70-71
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:WHEN HEATED TO DECOMPOSTION, AS IN A
FIRE OR IN WELDING, MAY PRODUCE TOXIC FUMES SUCH AS CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:INORGANIC DICHROMATE SOLUTION PR-1422 A-1 #1422A179
Kit Part:Y
CAGE:83574
CAGE:83574
============= Composition/Information on Ingredients =============
Ingred Name:CALCIUM DICHROMATE (SARA 313)
CAS:14307-33-6
RTECS #:HX7630000
Fraction by Wt: 15.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG/M3 STEL
ACGIH TLV:0.05 MG/M3
Ingred Name:WATER (NON-HAZARDOUS)
CAS:7732-18-5
RTECS #:ZC0110000
Other REC Limits:NONE RECOMMENDED
Ingred Name:MAGNESIUM ALUMINUM SILICATE (NON-HAZARDOUS)
CAS:7732-18-5
RTECS #:ZC0110000
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIMETHYLFORMAMIDE (CERCLA) VP = 3.7
CAS:68-12-2
RTECS #:LQ2100000
Fraction by Wt: 25.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL: 10 PPM, SKIN
ACGIH TLV: 10 PPM, SKIN
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: <5.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:MAGNESIUM DICHROMATE (SARA 313)
CAS:13423-61-5
Fraction by Wt: 25.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1MG/M3 STEL, CR03
ACGIH TLV:0.05 MG/M3, CR
Ingred Name:SILICA DERIVITIVES (NON-HAZARDOUS)
CAS:67762-90-7
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: BURN, TEAR, RED, POSSIBLE
TRANSIENT CORNEAL INUURY. SKIN: TOXIC ABSORPTION. INHAL: VOMIT,
DIFFICULTY SWALLOWING, DIARRHEA, LACK OF APPETITE, HEADACHE,
FAINTING, DIZZINESS, DARK URINE, MENTAL DIST URBANCE, LIVER DAMAGE.
*
Effects of Overexposure:NK *CHRONIC: PENETRATING ULCERS OF
SKIN/MUCOUS MEMBRANES OF NOSE & PERFORATION OF CARTILAGINOUS NASAL
SEPTUM.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LUKE WARM WATER FOR 15 MINUTES, CONSULT A
PHYSICIAN. SKIN: WASH WITH SOAP AND WATER. CONSULT A PHYSICIAN.
INHALATION: REMOVE TO FRESH AIR. CONSULT A PHYSICIAN. INGESTION:
CONSULT DR.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:USE COMPLETE PERSONAL PROTECTION.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE, COVER WITH NONOXIDIZABLE ABSORBENT
MATERIAL AND SCOOP INTO CONTAINER. SPRINKLE SODIUM THIOSULFATE ON
RESIDUE. WORK INTO RESIDUE. CLEAN AREA WITH WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID ALL SKIN CONTACT.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN APPLYING IN ANY CIRCUMSTANCES LIKELY TO
PRODUCE AIRBORNE LEVELS OF HAZARDOUS INGREDIENTS IN EXCESS OF TLV,
USE ORGANIC VAPOR CARTRIDGE RESPIRATOR OR AIR-SUPPLIED RESPIRATOR.
Ventilation:GENERAL VENITLATION TO MANTAIN VAPORS BELOW PEL.
Other Protective Equipment:APRON, COVERALLS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
SMOKING OR EATING.AVOID INGESTION. AVOID ALL SKIN CONTACT.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212 TO 307F
Vapor Density:>AIR
Spec Gravity:1.502
Evaporation Rate & Reference:SLOWER THAN BUAC
Appearance and Odor:BLACK PASTE
Percent Volatiles by Volume:69.8
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
EASILY OXIDIZABLE MATERIALS.
Hazardous Decomposition Products:OXIDES OF CARBON, NITROGEN, CHROMIUM
COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:D-007 EPA HAZARDOUS WASTE. DISPOSE OF IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:AUFHAUSER BORON FLUX
CAGE:59401
CAGE:59401
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM HYDROGEN FLUORIDE
CAS:7789-29-9
RTECS #:TS6650000
Fraction by Wt: 10 - 30%
Other REC Limits:2.5 MG M3
Ingred Name:POTASSIUM BOROFLUORIDE
CAS:14075-53-7
RTECS #:ED2800000
Fraction by Wt: 5 - 20%
Other REC Limits:2.5 MG/M3
OSHA PEL:2.5 MG/M3 AS F
ACGIH TLV:2.5 MG/M3 AS F
Ingred Name:POTASSIUM BORATE
CAS:1332-77-0
Fraction by Wt: 15 - 25%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM FLUORIDE
CAS:7789-23-3
RTECS #:TT0700000
Fraction by Wt: 5 - 15%
Other REC Limits:2.5 MG/M3
Ingred Name:BORIC ACID
CAS:10043-35-3
RTECS #:ED4550000
Fraction by Wt: 25 - 40%
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 15 - 35%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ORGANIC PIGMENT
Fraction by Wt: 1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE SPECIFIED FOR PRODUCT ITSELF. MFR
STATES INHALATION OF WELDING FUMES: DIZZINESS, NAUSEA, DRYNESS OR
IRRITATION OF NOSE, THROAT OR EYES, TIGHTNESS OF CHEST, FEVER,
ALLERGIC REACTIONS. CHRONIC OVER EXPOSURE TO WELDING FUMES:
SIDEROSIS, PULMONARY AFFECTS. ARC RAYS AND HEAT RAYS CAN INJURE
EYES AND BURN SKIN.
Explanation of Carcinogenicity:NONE OF THE INGREDIENTS IN THIS PRODUCT
ARE LISTED AS A CARCINOGEN BY NTP, IARC, OR OSHA.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER FOR THE PRODUCT
ITSELF.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER FOR
THE PRODUCT ITSELF.
======================= First Aid Measures =======================
First Aid:EMPLOY FIRST AID TECHNIQUES RECOMMENDED BY THE AMERICAN RED
CROSS. IF BREATHING IS DIFFICULT GIVE OXYGEN. CALL A DOCTOR. IN
CASE OF ELECTRICAL SHOCK, DISCONNECT AND TURN OFF POWER. IF NOT
BREATHING GI VE ARTIFICIAL RESPIRATION. IF NO PULSE GIVE EXTERNAL
HEART MASSAGE. CALL A DOCTOR. IN CASE OF ARC BURN, CALL A DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NONCOMBUSTIBLE. USE EXTINGUISHING MEDIA APPROPRIATE
FOR SURROUNDING FIRE CONDITIONS.
Fire Fighting Procedures:WEAR A NIOSH APPROVED SELF-CONTAINED BREATHING
APPARATUS AND FULL PROTECTIVE EQUIPMENT WHEN FIGHTING FIRES. USE
WATER SPRAY TO COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:WILL RELEASE HYDROFLUORIC ACID AND BORON
TRIFLUORIDE FUMES UPON DECOMPOSITION.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRABLE FUME RESPIRATOR OR AIR SUPPLIED
RESPIRATOR WHEN WELDING IN CONFINED SPACE OR WHERE LOCAL EXHAUST OR
VENTILATION DOES NOT KEEP EXPOSURE BELOW TLV.
Ventilation:WHEN WELDING: VENTILATION AND OR LOCAL EXHAUST AT THE ARC
TO KEEP FUMES BELOW TLV'S IN BREATHING ZONE AND GENERAL AREA.
Other Protective Equipment:WHEN WELDING WEAR BODY PROTECTION WHICH
HELPS TO PREVENT INJURY FROM RADIATION, SPARKS, AND ELECTRICAL
SHOCK.
Work Hygienic Practices:WELDER'S SHOULD KEEP THEIR HEADS OUT OF THE
FUMES.
Supplemental Safety and Health
MSDS IS PER MANUFACTURER AND ONLY GIVES PRECAUTIONS FOR WELDING WITH
THIS PRODUCT.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.6
Evaporation Rate & Reference:0.3 (N-BUTYL ACETATE = 1)
Solubility in Water:MODERATE
Appearance and Odor:BLACK ODORLESS PASTE
Percent Volatiles by Volume:30
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:HIGH HEAT
Hazardous Decomposition Products:OXIDES OF POTASSIUM BIFLUORIDE,
POTASSIUM FLUOBORATE, CARBON MONOXIDE, CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARD ANY PRODUCT (INCLUDING ANY RETAINED
MATERIALS OF USE), DISPOSABLE CONTAINER OR LINER IN AN
ENVIRONMENTALLY ACCEPTABLE MANNER, IN FULL COMPLIANCE WITH LOCAL,
STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:14680-3 TO 14684-3 UHS CLEANER
Preparer's Name:TERRY A MEYERS
CAGE:0U826
CAGE:0U826
CAGE:32204
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTOXYETHANOL (ETHYLENE GLYCOL MONOBUTYL ETHER), BUTYL
CELLOSOLVE, BUTYL GLYCOL, GLYCOL ETHER EB
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 2-5%
Other REC Limits:25 PPM (SKIN)
OSHA PEL:25 PPM (SKIN)
ACGIH TLV:25 PPM (SKIN)
Ingred Name:2-AMINOETHANOL, ETHANOLAMINE, MONOETHANOLAMINE
CAS:141-43-5
RTECS #:KJ5775000
Fraction by Wt: 1-5%
Other REC Limits:3 PPM
OSHA PEL:3 PPM
ACGIH TLV:7.5 MG/CUM
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 80-95%
Ingred Name:AMMONIUM HYDROXIDE, AQUA AMMONIA
CAS:1336-21-6
RTECS #:BQ9625000
Fraction by Wt: 1-3%
Other REC Limits:25 PPM
OSHA PEL:35 PPM
ACGIH TLV:25 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOLATILE ORGANIC COMPOUNDS: 0.55 LB/GAL
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION. EYES: MODERATE
IRRITATION. INHALATION: MAY CAUSE IRRITATION TO NOSE, THROAT &
LUNGS. INGESTION: MAY BE HARMFUL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
Medical Cond Aggravated by Exposure:PERSONS W/PRE-EXISTING SKIN
DISORDERS MAY BE MORE SUSCEPTIBLE TO IRRITATING EFFECTS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15-20 MINS. SKIN: WASH W/PLENTY OF
WATER. INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:NORMAL FIRE FIGHTING PROCEDURES MAY BE USED.
Unusual Fire/Explosion Hazard:NO SPECIAL HAZARDS KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:LARGE: DIKE & ABSORB W/OIL-DRI/SIMILAR INERT
MATERIAL. SWEEP/SCRAPE UP & CONTAINERIZE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING. DON'T BREATHE
PRODUCT MISTS IN HIGH SPEED SCRUBBING.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID
PROLONGED/REPEATED CONTACT W/EYES & REPEATED/PROLONGED CONTACT
W/SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF MISTS/VAPORS ARE NOT ADEQUATELY CONTROLLED BY
LOCAL VENTILATION, USE APPROPRIATE RESPIRATORY PROTECTION TO
PREVENT EXPOSURE.
Ventilation:GENERAL ROOM: NORMALLY ADEQUATE. LOCAL EXHAUST: TO CONTROL
SUBSTANTIAL AMOUNTS OF MISTS/VAPORS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
PH: 11.2-12
================== Physical/Chemical Properties ==================
Spec Gravity:1.01
pH:(SUPP)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR GREEN-BLUE LIQUID W/AMMONIA ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:FREEZING.
Hazardous Decomposition Products:NORMAL PRODUCTS OF COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:UNDILUTED PRODUCT: DISPENSE UNDER THE RCRA AS A
CORROSIVE WASTE. DISPOSE OF REGULATED QUANTITIES SHOULD BE BY
NEUTRALIZATION AT A PERMITTED FACILITY IAW/FEDERAL, STATE & LOCAL
REGULATIONS. UN1760.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HYDROGEN SULFIDE IN NITROGEN 0.1 PPM TO 5%
CAGE:NORLA
CAGE:NORLA
CAGE:0YFB8
============= Composition/Information on Ingredients =============
Ingred Name:NITROGEN
CAS:7727-37-9
RTECS #:QW9700000
Fraction by Wt: 95-99.0%
ACGIH TLV:ASPHYXIANT
Ingred Name:HYDROGEN SULFIDE
CAS:7783-06-4
RTECS #:MX1225000
Fraction by Wt: .0001-5%
Other REC Limits:10 PPM
ACGIH TLV:14 MG/CUM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: HYDROGEN SULFIDE WILL CAUSE
CONJUNCTIVA IRRITATION & CONJUCTIVITIS. SKIN: MAY IRRITATE.
INGESTION: IRRITATION OF THE GI TRACT. INHALATION: IRRITATION OF
MUCOUS MEMBRANES, BURNING & EXPOSURE TO L OW CONCENTRATIONS. HIGH
CONCENTRATIONS MAY CAUSE RESPIRATORY ARREST. EXPOSURES GREATER THAN
700 PPM MAY BE FATAL. (SUPP)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:HYDROGEN SULFIDE: IRRITATION, PHOTO PHOBIA,
CORNEAL BULLAC, TEARING, PAIN, BLURRED VISION, BURNING, SALIVATION,
HEADACHE, DIZZINESS, NAUSEA, FATIGUE, PARALYSIS, COMA,
UNCONSCIOUSNESS. NITROGEN: ASPHYX IANT, DIZZINESS, DEEPER
BREATHING, AIR HUNGER, NAUSEA, UNCONSCIOUSNESS.
Medical Cond Aggravated by Exposure:BLOOD DISORDERS.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/LOW PRESSURE, COOL WATER FOR 15
MINS. SKIN: FLUSH AREA W/COPIOUS AMOUNTS OF WATER.
INHALATION/INGESTION: RESCUE PERSONNEL SHOULD BE EQUIPPED W/SCBA.
IF CONSCIUOS, REMOVE TO F RESH AIR. IF UNCONSCIOUS, GIVE CPR/OXYGEN
IF NEEDED. TREAT SYMPTOMATICALLY & SUPPORTIVELY. KEEP WARM & QUIET.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:GAS
Lower Limits:4
Upper Limits:44
Extinguishing Media:WATER, CO2, DRY CHEMICAL
Fire Fighting Procedures:IF POSSIBLE, STOP FLOW OF GAS; USE WATER SPRAY
TO COOL SURROUNDING CONTAINERS. KEEP APPARATUS AWAY FROM AREAS
WHERE FLAMMABLE GAS MAY ACCUMULATE.
Unusual Fire/Explosion Hazard:HYDROGEN SULFIDE IS FLAMMABLE IN AIR OVER
A WIDE RANGE. ELIMINATE SOURCES OF IGNITION. INCREASE VENTILATION
TO PREVENT EXPLOSION HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. USE APPROPRIATE PROTECTIVE
EQUIPMENT. IF LEAKING, PURGE PIPE W/AN INERT GAS PRIOR TO
ATTEMPTING REPAIRS. IF A LEAK IS IN CONTAINER/CONTAINER VALVE,
CONTACT NORCO FOR ASSISTANCE. STOP FL OW OF GAS. EXTINGUISH
IGNITION SOURCES.(SEE SUPP)
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT CYLINDERS FROM PHYSICAL
DAMAGE. STORE IN COOL, DRY, WELL VENTILATED AREA AWAY FROM HEAVILY
TRAFFICKED AREAS & EMERGENCY EXITS.
Other Precautions:DON'T ALLOW TEMPS TO EXCEED 125F. CYLINDERS SHOULD BE
STORED UPRIGHT & SECURED TO PREVENT FALLING/BEING KNOCKED OVER.
CLOSE VALVE AFTER EACH USE & WHEN CONTAINER IS EMPTY. DON'T DRAG,
SLIDE/ROLL CYLIN DERS ON THEIR SIDES. (SEE SUPP)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A TYPE C RESPIRATOR W/FULL FACE PIECE EQUIPPED
W/AN ESCAPE BOTTLE/A SCBA SHOULD BE AVAILABLE FOR EMERGENCY
USE/WHEN CONCENTRATIONS EXCEED EXPOSURE LIMITS.
Ventilation:LOCAL EXHAUST TO REDUCE CONCENTRATIONS TO W/IN EXPOSURE
LIMITS. A LABORATORY TYPE HOOD IS SUITABLE FOR HANDLING.
Other Protective Equipment:POLY VINYL CHLORIDE, POLYETHYLENE, SAFETY
SHOES, SAFETY SHOWER, EYEWASH FOUNTAIN.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:SLIGHT
Appearance and Odor:A COLORLESS, FLAMMABLE GAS/LIQUID W/A ROTTEN EGG
ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
METALS, COPPER, COPPER BASE MATERIALS, BRASS.
Stability Condition to Avoid:HEAT, SPARK, OPEN FLAME & OTHER IGNITION
SOURCES.
Hazardous Decomposition Products:OXIDES OF SULFUR, HYDROGEN SULFIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T ATTEMPT TO DISPOSE OF WASTE/UNUSED
QUANTITIES. RETURN IN SHIPPING CONTAINER PROPERLY LABELED, W/ANY
VALVE OUTLET PLUGS/CAPS SECURE & VALVE PROTECTION CAP TO NORCO FOR
PROPER DISPOSAL IAW/FEDERAL , STATE & LOCAL REGULATIONS.
NONFLAMMABLE UN1956.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CARB-N-RID
CAGE:4S446
CAGE:4S446
============= Composition/Information on Ingredients =============
Ingred Name:AROMATIC HYDROCARBON
Fraction by Wt: 27%
Other REC Limits:NONE RECOMMENDED
Ingred Name:KETONE
Fraction by Wt: 27%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:50 PPM
Ingred Name:CHLORINATED HYDROCARBONS
Fraction by Wt: 14%
Other REC Limits:NONE RECOMMENDED
Ingred Name:CYCLIC AMIDE
Fraction by Wt: 7.55%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:200 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN-IRRITATION, DEFATTING,
DERMATITIS.INHAL:MAY CAUSE CNS EFFECTS.
Explanation of Carcinogenicity:NOT CARCINOGENIC.
Effects of Overexposure:INHAL:DIZZINESS, WEAKNESS, NAUSEA, HEADACHE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN-THOROUGHLY WASH EXPOSED AREA WITH SOAP AND WATER. REMOVE
CONTAMINATED CLOTHING. EYES-FLUSH WITH LARGE AMOUNTS OF WATER,
LIFTING UPPER & LOWER LIDS OCCASIONALLY. GET MEDICAL ATTENTION.
INGESTION-D O NOT INDUCE VOMITING. KEEP PERSON WARM, QUIET AND GET
MEDICAL ATTENTION. INHALATION-REMOVE VICTIM TO FRESH AIR. GIVE
ARTIFICIAL RESPIRATION IF BREATHING HAS STOPPED.
===================== Fire Fighting Measures =====================
Flash Point:FLAME EXTEN 18'
Extinguishing Media:WATER, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS WITH A FULL
FACEPIECE OPERATED IN PRESSURE-DEMAND OR OTHER POSITIVE PRESSURE
MODE.USE WATER FOG TO COOL FIRE EXPOSED CONTNRS.
Unusual Fire/Explosion Hazard:CONTAINERS MAY BURST FROM HEAT OF FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB LIQUID AND TRANSFER UNDER VENTILATION
HOOD.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT DROP CONTAINER. KEEP OUT OF SUN
AND BELOW 110F.
Other Precautions:DO NOT KEEP OR USE IN THE PRESENCE OF HEAT, SPARKS,
AND OPEN FLAME. USE WITH ADEQUATE VENTILATION. HARMFUL OR FATAL IF
SWALLOWED. CONTAINS PETROLEUM DISTILLATES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE EITHER A SELF-CONTAINED BREATHING APPARATUS
OR NIOSH RESPIRATOR FOR ORGANIC VAPORS,DEPENDING ON THE EXPOSURE
LEVEL.
Ventilation:LOCAL EXHUAST AND MECHANICAL(GENERAL).
Other Protective Equipment:PROTECTIVE CLOTHING AS NEEDED.PROVIDE A
LOCAL EYE WASH STATION.
Work Hygienic Practices:USE REASONABLE CARE IN HANDLING THIS ITEM.WASH
HANDS AFTER USING.
Supplemental Safety and Health
REDORD UPDATED IAW TSR,03JAN97,SSGT BENAVIDEZ,89 TRNS/LGTTC).
================== Physical/Chemical Properties ==================
HCC:V3
Appearance and Odor:AEROSOL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:HIGH HEAT, SOUCES OF IGNITION.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE CAN. WRAP AND DISCARD IN TRASH
COLLECTION.DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DC4XX ALKYD SEMIGLOSS ENAMEL, DC450 ANTIQUE WHITE
CAGE:FO133
CAGE:97903
CAGE:FO133
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 35%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 25%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC; (MINERAL
SPIRITS) VP: 2.0 @ 68F
CAS:64742-88-7
Fraction by Wt: 25%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:ALKYD RESIN
Fraction by Wt: 25%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:LINSEED OIL; (RAW LINSEED OIL)
CAS:8001-26-1
RTECS #:OI9690000
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC CONTENT: 340.9 G/L (LESS WATER)
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUP DAT: SYMPTOMS MAY NOT BE IMMEDIATELY APPARENT. OBTAIN
MEDICAL ATTENTION.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: ASPIR OF VOMITUS CAN CAUSE CHEM PNEUMIT
WHICH CAN BE FATAL. WARNING: INTENTIONAL MISUSE BY (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: DELIBERATELY CONCENTRATING AND INHALING THE CONTENTS
MAY BE HARMFUL OR FATAL.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: STORE IN CLOSED CONTAINERS UNTIL PROPERLY
DISPOSED OF.
RTECS #:9999999ZZ
Ingred Name:RESP PROT: & SANDING DUST. WHEN USED IN RESTRICTED AREAS,
WEAR NIOSH/MSHA APPRVD CHEM/MECH FILTERS DESIGNED TO (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: REMOVE COMBINATION OF PARTICULATES & VAP. WHEN USED
IN CONFINED AREAS, WEAR NIOSH/MSHA APPRVD AIR SUPP (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: RESP/HOODS. USE NIOSH/MSHA APPRVD RESP WHEN FLAME
CUTTING, WELDING, BRAZING & SANDING MATL COATED W/ (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: THIS PRODUCT. FOLLOW RESPIRATOR MFR'S DIRECTIONS
FOR RESPIRATOR USE.
RTECS #:9999999ZZ
Ingred Name:VENT: CURRENT APPLIC SFTY & HLTH STDS IN MIXING,
APPLICATION & CURING AREAS, & TO REMOVE SANDING DUSTS OF DRIED (ING
16)
RTECS #:9999999ZZ
Ingred Name:ING 15: COATING & DECOMP PROD DURING WELDING & FLAME
CUTTING ON SURF COATED W/THIS PROD. HEAVY SOLV VAPS SHOULD (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: BE REMOVED FROM LOWER LEVELS OF THE WORK AREA AND
ALL IGNITION SOURCES SHOULD BE ELIMINATED.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: IRRIT OF RESP TRACT. MAY
AFFECT BRAIN/NERV SYS CAUSING DIZZ, HDCH, NAUS, WEAK & FATG.
EXTREME EXPOS CAN RSLT IN UNCON & EVEN RESP ARREST. EYE/SKIN:
IRRIT. INGEST: CAN CAUSE STOM &/INTEST INAL IRRIT, NAUS, VOMIT &
DIARR. ASPIR OF VOMITIS CAN CAUSE CHEM PNEUMIT, WHICH CAN BE FATAL.
(EFFECTS OF OVEREXPOSURE)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: CHRONIC: REPORTS HAVE ASSOC RPTD &
PRLNG OCCUP OVEREXP TO SOLV W/PERM BRAIN & NERV SYS DMG. PRLNG &
RPTD BRTHG OF SPRAY MIST &/SANDING DUST OVER PERIOD OF YRS MAY
CAUSE DUST DISEASE OF LUNGS . THIS PROD MAY CONTAIN CHEM KNOWN TO
STATE OF CALIFORNIA TO CAUSE CANCER, BIRTH DEFECTS/OTHER REPRO HARM
(CAL PROP 65).
Medical Cond Aggravated by Exposure:NONE WHEN USED IN ACCORDANCE WITH
SAFE HANDLING AND USE INFORMATION.
======================= First Aid Measures =======================
First Aid:INHAL: IF DFCLT BRTHG, OBTAIN FRESH AIR. IF CONTINUED DFCLT
IS EXPERIENCED, SUMMON MED ASSIST IMMED. IF BRTHG CEASES, RESTORE
USING APPRVD CPR TECHNIQUES & SUMMON MED ASSIST IMMED. EYES: FLUSH
W/LGE A MTS OF WATER FOR AT LEAST 15 MIN. GET MED ASSIST. SKIN:
WASH AREA THORO W/SOAP & WATER. REMOVE SOILED CLTHG. GET MED ASSIST
IF IRRIT PERSISTS. INGEST: DO NOT INDUCE VOMIT. CONSULT MD IMMED.
(ING 8)
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:102F,39C
Lower Limits:SEE ING 3
Extinguishing Media:USE CARBON DIOXIDE, DRY CHEMICAL, FOAM OR OTHER
NFPA APPROVED METHOD FOR TREATING A CLASS B FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. SUMMON PROFESSIONAL FIREFIGHTERS. WATER SPRAY MAY BE INEFFECTIVE.
IF WATER IS USED, FOG NOZZ ARE (SUP DAT)
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY CLSD. ISOLATE FROM
HEAT & FLAME. DUE TO PRESS BUILD-UP, CLSD CONTRS EXPOSED TO EXTREME
HEAT MAY EXPLODE. NEVER USE WELDING/CUTTING (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT (HEAT, FLAME). DO
NOT SMOKE. AVOID BRTHG VAPS. BEFORE ATTEMPTING CLEAN-UP REFER TO
HAZ CAUTION INFO IN OTHER SECTIONS OF THIS MSDS. VENT AREA. CONTAIN
SPILLED MATL & REMOVE W/INERT ABSORB & NON-SPARKING TOOLS. (ING
10)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT & FLAME. DO NOT
SMOKE. PVNT BUILD-UP OF VAPS BY MAINT CONTINUOUS FLOW OF FRESH AIR.
DO NOT STORE > 120F/NEAR FIRE/OPEN FLAME.
Other Precautions:STORE LGE QTYS IN BLDGS DESIGNED TO COMPLY W/OSHA
1910.106. KEEP CONTR CLSD WHEN NOT IN USE. DO NOT TRANSFER CONTENTS
TO BOTTLES/OTHER UNLABELLED CONTRS. DO NOT REUSE EMPTY CONTRS. KEEP
OUT OF REACH O F CHILDREN. DO NOT GET IN EYES/ON SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DO NOT BREATHE VAPS, SPRAY MIST/SANDING DUST.
WHEN SPRAY APPLIED IN OUTDOOR/OPEN AREAS W/UNRESTRICTED VENT &
DURING SANDING/GRINDING OPERATIONS, USE NIOSH/MSHA APPRVD MECH
FILTER RESP TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY (ING
11)
Ventilation:USE ONLY W/ADEQ VENT. PROVIDE GEN DILUTION/LOC EXHAUST VENT
IN VOL & PATTERN TO KEEP AIR CONTAM CONC BELOW (ING 15)
Other Protective Equipment:SOLVENT IMPERMEABLE CLOTHING & BOOTS
RECOMMENDED. EMERGENCY EYEWASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA .
Work Hygienic Practices:REMOVE AND WASH SOILED CLOTHING BEFORE REUSE.
WASH HANDS BEFORE EATING, SMOKING OR USING THE WASHROOM.
Supplemental Safety and Health
FIRE FIGHT PROC: PREFERABLE. IF EXPOSED TO FIRE/EXTREME HEAT, WATER
SHOULD BE USED TO COOL CLSD CONTRS & PVNT PRESS BUILD-UP/POSS
AUTO-IGNIT. EXPLO HAZ: TORCH ON/NEAR CONTR (EVEN EMPTY) AS PROD/ITS
RE SIDUE MAY IGNITE. DURING EMER CNDTNS, OVEREXP TO DECOMP PRODS
MAY CAUSE A HLTH HAZ. (ING 7)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>310F,>154C
Vapor Pres:SEE ING 3
Vapor Density:HVR/AIR
Spec Gravity:1.34
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER
Percent Volatiles by Volume:45.3
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY CAUSE HAZ FUMES WHEN HEATED TO
DECOMP. FUMES MAY CONTAIN CARBON MONOXIDE/DIOXIDE & OXIDES OF
METALS LISTED IN INGS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS. INCINERATE ONLY IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:140-2494 DOVER WHITE, SUPER ACRYLIC (SUPP DATA)
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:PROPANE; (PROPELLANT). VP:760.
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 14%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT
Ingred Name:BUTANE; (PROPELLANT). VP:760.
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: 13%
OSHA PEL:800 PPM
ACGIH TLV:800 PPM
Ingred Name:TOLUENE (SARA 313) (CERCLA). VP:22.
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 24%
OSHA PEL:200 PPM
ACGIH TLV:50 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BENZENE, ETHYL-; (ETHYLBENZENE) (SARA 313). VP:7.1.
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 1%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM;125 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE (SARA 313) (CERCLA). VP:5.9.
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 7%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM;150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE (SARA 313) (CERCLA). VP:180.
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 16%
OSHA PEL:1000 PPM
ACGIH TLV:750 PPM;1000 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPIONIC ACID, 3-ETHOXY-, ETHYL ESTER;
(ETHYL-3-ETHOXYPROPIONATE). VP:1.1.
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: 3%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 9%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:SUPDAT:ATTAINABLE IN WORKPLACE. RPTS HAVE ASSOC RPTD &
PRLNG OVEREXP TO SOLVS W/PERM BRAIN & NERV SYS DMG. (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:INTENTIONAL MISUSE BY DELIB CONCENTRATING & INHALING
CONTENTS CAN BE HARMFUL/FATAL. THESE PRODS CONTAIN (ING 12)
RTECS #:9999999ZZ
Ingred Name:SUPDAT:CHEM(S) KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER & BIRTH DEFECTS/OTHER REPRO HARM. NOTE:TOLUENE (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:APPEARS ON THE NAVY LIST OF OCCUP CHEM REPRO HAZS.
SEEK CONSULTATION FROM APPROP HLTH PROFESSIONALS (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:CONCERNING LATEST HAZARD LIST INFORMATION & SAFE
HANDLING & EXPOSURE INFORMATION .
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:GROUNDING PROCS. CONTENTS UNDER PRESS. DO NOT
PUNCTURE, INCIN/EXPOSE TO TEMP >120F. HEAT FROM (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:SUNLIGHT, RADIATORS, STOVES, HOT WATER & OTHER HEAT
SOURCES COULD CAUSE CNTNR TO BURST. DO NOT TAKE (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:INTERNALLY. KEEP OUT OF REACH OF CHILDREN. USE ONLY
W/ADEQ VENT. AVOID BRTHG VAP & SPRAY MIST. AVOID CONT(ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:W/SKIN & EYES. THESE COATINGS MAY CONTAIN MATLS
CLASSIFIED AS NUISANCE PARTICULATES WHICH MAY BE PRESENT (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:AT HAZ LEVELS ONLY DURING SANDING/ABRADING OF DRIED
FILM. IF NO SPECIFIC DUSTS ARE LISTED, APPLIC LIMS (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19:FOR NUISANCE DUSTS ARE ACGIH TLV 10 MG/M3 (TDUST);
OSHA PEL 15 MG/M3 (TDUST), 5 MG/M3 (RESPIRABLE FRACTION).
RTECS #:9999999ZZ
Ingred Name:RESP PROT:PROTECTION AGAINST NON-VOLATILE INGREDIENTS.
RTECS #:9999999ZZ
Ingred Name:VENT:EXPOSURE LIMITS. REFER TO OSHA STANDARDS 1910.94,
1910.107, 1910.108.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPOS MAY BE BY INHAL &/OR SKIN/EYE
CONT, DEPENDING ON CNDTNS OF USE. TO MIN EXPOS, FOLLOW RECS FOR
PROPER USE, VENT & PERSONAL PROT EQUIP. ACUTE:IRRIT OF EYES, SKIN &
RESP SYS. MAY CAUSE NERV SYS DEP RESS. EXTREME OVEREXP MAY RSLT IN
UNCON& POSS DEATH. HDCH, DIZZ, NAUS & LOSS OF COORD ARE INDICATIONS
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:OF EXCESSIVE EXPOS TO VAPS/SPRAY
MISTS. REDNESS & ITCH/BURNING SENSATION MAY INDICATE EYE/EXCESSIVE
SKIN EXPOS. CHRONIC:PRLNG OVEREXP TO SOLV INGS MAY CAUSE ADVERSE
EFTS TO LIVER, URINARY, CV S & REPRO SYS. RATS EXPOS TO TITANIUM
DIOXIDE DUST AT 250 MG/M3 DEVELOPED LUNG CANCER, HOWEVER, SUCH
EXPOS (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM &
QUIET. SKIN:WASH AFFECTED AREA THOROUGHLY W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING & LAUNDER BEFORE RE-USE. EYES:FLUSH W/LARGE
AMOUNTS OFWATER FOR AT LEAST 15 MINUTES. GET MEDICAL ATTENTION.
INGEST:SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:<0F,<-18C
Lower Limits:0.7%
Upper Limits:12.8%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
WATER SPRAY MAY BE INEFT. IF WATER IS USED, FOG NOZZ ARE PREF.
WATER MAY BE USED TO COOL CLSD CNTNRS(SUPDAT)
Unusual Fire/Explosion Hazard:EXTREMELY FLAMM. ISOLATE FROM HEAT, ELEC
EQUIP, SPKS & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN EXPOS TO
EXTREME HEAT. APPLICATION TO HOT SURFS REQS (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE &
REMOVE W/INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DOL STOR CATEGORY-1A. CONTENTS ARE
EXTREMELY FLAMM. KEEP AWAY FROM HEAT, SPKS & OPEN FLAME. VAPS WILL
ACCUM READILY & MAY IGNITE EXPLOSIVELY.
Other Precautions:DURING USE & UNTIL ALL VAPS ARE GONE: KEEP AREA
VENTILATED; DO NOT SMOKE; EXTING ALL FLAMES, PILOT LIGHTS &
HEATERS; TURN OFF STOVES, ELEC TOOLS & APPLIANCES & ANY OTHER
SOURCES OF IGNIT. CONSULT NFPA CODE. USE APPRVD BONDING & (ING 15)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIMS BY VENT, WEAR A PROPERLY FITTED NIOSH/MSHA APPRVD ORG
VAP/PARTICULATE RESP FOR PROT AGAINST INGS. WHEN SANDING/ABRADING
DRIED FILM, WEAR A NIOS H/MSHA APPRVD DUST/MIST RESP FOR(ING 21)
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF
EXPOSURE TO INGREDIENTS IS MAINTAINED BELOW APPLICABLE (ING 22)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:CONTROLS RUST SPRAY ENAMEL. FIRE FIGHT PROC:TO
PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN EXPOS TO EXTREME
HEAT. EXPLO HAZ:SPECIAL PRECS. DURING EMER CNDTNS OVEREXP TO DE
COMP PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE IMMED APPARENT.
OBTAIN MED ATTN. EFTS OF OVEREXP:LEVELS ARE NOT (ING 10)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:<342F,<172C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Volatile Org Content %:78
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THIS PROD MAY BE HAZ AS DEFINED UNDER
THE RCRA (40 CFR 261). WASTE MUST BE TESTED FOR IGNITABILITY TO
DETERMINE APPLIC EPA HAZ WASTE NUMBERS. DO NOT INCIN. DEPRESSURIZE
CNTNR. DISP OF I/A/W FED, STATE & LOC REGS REGARDING POLLUTION.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MIL-I-25135E TYPE I,LEVEL 4,METHOD D (H 91 A EMULSIFIER)
CAGE:82925
CAGE:82925
============= Composition/Information on Ingredients =============
Ingred Name:DIETHYLENE GLYCOL MONOBUTYL ETHER
CAS:112-34-5
RTECS #:KJ9100000
Fraction by Wt: 45 - 55%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NONIONIC SURFACTANTS
CAS:68145-97-2
Fraction by Wt: 45 - 55%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SUBSTITUTED IMIDAZOLINE
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:LIVER, KIDNEY, BLOOD.
ACUTE- MAY CAUSE EYE IRRITATION, SKIN DERMATITIS. CAN BE ABSORBED
THROUGH SKIN. INHALATION OF VAPORS AT ELEVATED TEMPERATURES MAY
CAUSE RESPIRATORY IRRITATION. MAY BE HARMFUL IF SWALLOWED. MAY
CAUSE VOMITING. ASPIRATION HAZARD. CHRONIC- MAY CAUSE LIVER,
KIDNEY, BLOOD EFFECTS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, PAIN, DIZZINESS, HEADACHE, NAUSEA,
VOMITING, DERMATITIS
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION MAY BE
MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. EYES:FLUSH WITH WATER FOR 15 MINUTES, HOLDING EYELIDS OPEN.
SKIN:WASH WITH SOAP & WATER. ORAL:DO NOT INDUCE VOMITING. CALL
PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>212F,>100C
Lower Limits:0.9
Upper Limits:24.6
Extinguishing Media:USE CARBON DIOXIDE, FOAM OR DRY CHEMICAL. USE WATER
SPRAY TO COOL FIRE EXPOSED CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. EVACUATE PERSONNEL TO A SAFE
AREA.
================== Accidental Release Measures ==================
Spill Release Procedures:PREVENT SKIN AND EYE CONTACT. ABSORB SPILLS
WITH INERT MATERIAL SUCH AS SAND OR VERMICULITE. SCRAPE SPILL UP
INTO PROPER CONTAINERS FOR DISPOSAL. DO NOT FLUSH TO SEWER OR
WATERWAYS..
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINER, AWAY FROM
STRONG OXIDIZING AGENTS.
Other Precautions:WASH THOROUGHLY WITH SOAP AND WATER AFTER HANDLING
AND BEFORE EATING, DRINKING, SMOKING. KEEP OUT OF REACH OF
CHILDREN. DO NOT TAKE INTERNALLY. DO NOT INHALE. DO NOT GET IN EYES
OR ON SKIN. DO NOT CUT , PUNCTURE OR WELD EMPTY DRUMS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCENTRATION IS HIGH, WEAR A
NIOSH-APPROVED ORGANIC VAPOR RESPIRATOR.
Ventilation:ADEQUATE
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER, PROTECTIVE
CLOTHING
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:>446F,>230C
Vapor Pres:1
Vapor Density:>1
Spec Gravity:0.98
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:MISCIBLE
Appearance and Odor:RED LIQUID - SLIGHT FRUITY ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. INCINERATION IS RECOMMENDED.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SODIUM THIOSULFATE POWDER PILLOWS, 22937
CAGE:4T252
CAGE:91224
CAGE:4T252
============= Composition/Information on Ingredients =============
Ingred Name:THIOSULFURIC ACID, DISODIUM SALT; (SODIUM THIOSULFATE,
ANHYDROUS)
CAS:7772-98-7
RTECS #:XN6476000
Fraction by Wt: 100%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS PRODUCT MAY BE IRRITATING TO EYES
AND RESPIRATORY TRACT. ACUTE TOXICITY: MODERATELY TOXIC. CHRONIC
TOXICITY: NOT DETERMINED. OVEREXPOSURE MAY CAUSE DIARRHEA IF
SWALLOWED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE REPORTED.
======================= First Aid Measures =======================
First Aid:EYE/SKIN: IMMEDIATELY FLUSH EYES W/WATER FOR A MINIMUM OF 15
MINUTES. CALL MD. FLUSH SKIN W/PLENTY OF WATER. INGEST: INDUCE
VOMITING BY STICKING FINGER DOWN THROAT. NEVER GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS PERSON. CALL MD. INHAL: REMOVE TO FRESH
AIR. GIVE ARTIFICIAL RESPIRATION IF NECESSARY. CALL MD.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, CARBON DIOXIDE, OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MAY EMIT TOXIC FUMES; MAY REACT VIOLENTLY
WITH SODIUM NITRITE.
================== Accidental Release Measures ==================
Spill Release Procedures:COVER SPILL WITH SODA ASH OR SODIUM
BICARBONATE. MIX AND SPRAY WITH WATER. IF EFFERVESCENT WAIT UNTIL
REACTION IS COMPLETE. SCOOP INTO A LARGE BEAKER AND CAUTIOUSLY ADD
EQUAL VOLUME OF CALCIUM HYPOCHL ORITE (REACTION MAY BE VIGOROUS).
(SUPPDATA)
Neutralizing Agent:SEE SPILL/RELEASE PROCEDURE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE.
Other Precautions:AVOID CONTACT WITH EYES. DO NOT BREATHE DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:ADEQUATE VENTILATION.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PH: 6.5-8 AQ SOL. SPILL PROC: ADD MORE WATER, STIR, AND ALLOW TO STAND
FOR ONE HOUR. DILUTE AND NEUTRALIZE THE OXIDIZED SOLUTION AND
TRANSFER TO THE DRAIN WITH EXCESS WATER.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:>680F,>360C
Spec Gravity:1.69
pH:SUPDAT
Solubility in Water:VERY SOLUBLE
Appearance and Odor:SOLID COLORLESS CRYSTALS, ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTS VIOLENTLY WITH SODIUM NITRITE.
Stability Condition to Avoid:EXCESSIVE HEAT.
Hazardous Decomposition Products:HIGHLY TOXIC SULFUR OXIDE FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL,
STATE, AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:EXSPOR BASE CONCENTRATE, SODIUM CHLORITE
CAGE:3J700
CAGE:3J700
============= Composition/Information on Ingredients =============
Ingred Name:PER MSDS: HAZARDOUS INGREDIENTS/ID INFO: NOT APPLICABLE.
Fraction by Wt: NA
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM CHLORITE
CAS:7758-19-2
RTECS #:VZ4800000
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CAUSES TEMPORARY EYE IRRITATION ON
CONTACT.
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:SKIN:WASH W/SOAP/WATER.EYES:FLUSH IMMED W/WATER.GET MED ATTN
IF IRRIT PERSISTS.INGEST:GIVE MILK OR WATER.DONT INDUCE
VOMITING.FUME INHAL:EXPOSURE TO CLO2 GAS GENERATED BY ACCIDENTAL
CONTACT OF BASE CO NCENTRATE W/STRONG ACIDS,BLEACH,OR PEROXIDES
REQUIRES IMMED REMOVAL TO FRESH AIR & IMMED MED ATTN.
===================== Fire Fighting Measures =====================
Autoignition Temp:Autoignition Temp Text:NP
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:THE SOLUTION WILL NOT BURN.USE WATER TO COOL
FIRE-EXPO CONTAINERS.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH SPILLS W/WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID EYE COTNACT.
Other Precautions:NONE REQUIRED. EPAREG.#:45631-03.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:LOCAL EXHAUST:UNNECESSARY.
MECHANICAL(GEN)/SPECIAL/OTHER:NONE.
Other Protective Equipment:NONE
Work Hygienic Practices:WASH HANDS W/SOAP/WTER AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:B1
Boiling Pt:B.P. Text:213F,100C
Melt/Freeze Pt:M.P/F.P Text:30.4F,-0.9C
Decomp Temp:Decomp Text:NP
Vapor Pres:17
Vapor Density:NA
Spec Gravity:1.020
pH:12.0
Viscosity:NP
Evaporation Rate & Reference:SIMILAR TO WATER
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS TO PLAE YELLOW LIQUID; SLIGHT ODOR
Percent Volatiles by Volume:NP
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MINERAL ACIDS, BLEACH, PEROXIDES.
Stability Condition to Avoid:TEMEPRATURES ABOVE 120F.
Hazardous Decomposition Products:CLO2 GAS MAY BE GENERATED WHEN
COMBINED WITH MINERAL ACID, BLEACH, OR PEROXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DILUTE WITH WATER & FLUSH DOWN DRAIN.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FIX WOOD PATCH
CAGE:51405
CAGE:51405
CAGE:6F266
CAGE:1B236
CAGE:6X798
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 16.8%
Other REC Limits:NONE SPECIFIED
OSHA PEL:750 PPM;STEL 1000PPM
ACGIH TLV:750 PPM;STEL 1000PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:BUTYL ACETATE
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 6.3%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM;STEL 200 PPM
ACGIH TLV:150 PPM;STEL 200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 5.6%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM;STEL 300 PPM
ACGIH TLV:200 PPM;STEL 300 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:LACTOL SPIRITS
CAS:64741-55-5
Fraction by Wt: 11.83%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM
ACGIH TLV:200 PPM
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 1.7%
Other REC Limits:NONE SPECIFIED
OSHA PEL:400 PPM;STEL 500 PPM
ACGIH TLV:400 PPM;STEL 500 PPM
Ingred Name:NITROCELLULOSE (OSHA REGS, INCLUDING HAZARD COMMUNICATION
29 CFR 1910.1200, REGARDS INGRED NOT HEALTH HAZARD)
CAS:9004-70-0
RTECS #:QW0970000
Fraction by Wt: 3.9%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT GIVEN FOR PRODUCT AS A WHOLE
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION MAY CAUSE IRRITATION OF THE
RESPIRATORY TRACT AND CNS DEPRESSION. CONTACT WITH THE EYE/SKIN MAY
CAUSE IRRITATION. INGESTION MAY RESULT IN IRRITATION OF THE
RESPIRATORY TRACT AND CNS DEPRESS ION.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION, TEMPORARY CORNEAL DAMAGE, EYE
REDNESS/PAIN, SKIN IRRITATION, IRRITATION OF THE NOSE AND/OR
THROAT, HEADACHE, NAUSEA, VOMITING, DIZZINESS, NARCOSIS,
RESPIRATORY FAILURE, LOW BLOOD PRESS URE, GASTROINTESTINAL
IRRITATION, MOUTHIRRITATION, HEMATEMESIS, HEMORRHAGE, FLUSHING,
STUPOR, INCOORDINATION, COMA.
Medical Cond Aggravated by Exposure:ASTHMA AND ANY OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA, AND DERMATITIS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH WITH SOAP AND WATER. IF IRRITATION PERSIST, GET MEDICAL
ATTENTION. INH ALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. GET
MEDICAL ATTENTION. INGESTION: DO NOT INDUCE VOMITING. GET
IMMEDIATLE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:-4F,-20C
Autoignition Temp:Autoignition Temp Text:869 F
Lower Limits:2.50 %
Upper Limits:13.0 %
Extinguishing Media:ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER
FOG
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR SELF CONTAINED
BREATHING APPARATUS AND FULL PROTECTIVE GEAR. COOL TANKS AND
CONTAINERS EXPOSED TO FIRE WITH WATER.
Unusual Fire/Explosion Hazard:DRY WOOD PATCH CONTAINS A SMALL
PERCENTAGE OF NITROCELLULOSE WHICH IS READILY IGNITABLE AND BURNS
WITH INTENSE HEAT. BURNING GENERATES TOXIC FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP ALL SOURCES OF IGNITION AND HOT METAL
SURFACES ISOLATED FROM SPILL. AVOID BREATHING VAPORS. PROVIDE
ADEQUATE VENTILATION. PICK UP WITH A SCOOP OR SMALL SHOVEL. PLACE
IN APPROPRIATE CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP PRODUCT CONTAINERS COOL, DRY AND
AWAY FROM SOURCES OF IGNITION. KEEP FROM FREEZING. USE AND STORE
PRODUCT WITH ADEQUATE VENTILATION.
Other Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN USE. KEEP OUT OF
REACH OF CHILDREN. DO NOT TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURE MAY OR DOES EXCEED OCCUPATION
EXPOSURE LIMITS USE A NIOSH-APPROVED RESPIRATOR TO PREVENT
OVEREXPOSURE. IN ACCORD WITH 29 CFR 1910.134 USE EITHER AN
ATMOSPHERE-SUPPLYING RESPIRATOR OR AN AI R-PURIFYING RESPIRATOR.
Ventilation:EXHAUST VENTILATION SUFFICIENT TO KEEP AIRBORNE
CONCENTRATIONS BELOW RESPECTIVE TLV'S.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:NOT GIVEN
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:184
Vapor Density:NOT GIVEN
Spec Gravity:1.28
Evaporation Rate & Reference:< 1 (ETHER=1)
Solubility in Water:PARTIAL
Appearance and Odor:LIGHT BROWN PASTE WITH ACETONS ODOR
Percent Volatiles by Volume:41.64%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, ALKALINE MATERIALS AND STRONG ACIDS.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:IRIDITE 14-2
CAGE:1L168
CAGE:1L168
CAGE:1L164
============= Composition/Information on Ingredients =============
Ingred Name:CHROMIC ACID(MIXTURE), 30%HEXAVALENT CHROME BASIS
RTECS #:GB2650000
Fraction by Wt: UNK
ACGIH TLV:25 UG/CUM
Ingred Name:FLUORIDE
Fraction by Wt: 9%
Ingred Name:METALLIC CHROMATE
Fraction by Wt: UNK
OSHA PEL:C, 0.1 MG/M3 (CRO3)
ACGIH TLV:0.05 MG/M3 (CR);8990
Ingred Name:FERRIC CYANIDE SALT
Fraction by Wt: 10%
===================== Hazards Identification =====================
Effects of Overexposure:SKIN:ULCERS;MUCOUS
MEMBRANES:ATTACKED,IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES,SKIN:IMMEDIATELY FLUSH EXPOSED AREA W H*2O FOR 15
MIN;REMOVE CONTAMINATED CLOTHING;INGESTED:GIVE MILK,INDUCE
VOMITING;GET MEDICAL ATTENTION. NOTE:TREAT SAME AS CHROMIC ACID.
===================== Fire Fighting Measures =====================
Extinguishing Media:H*2O OR FOAM.
Fire Fighting Procedures:AVOID PERSONAL CONTACT & CONTACT W ORGANIC
MATERIALS.
Unusual Fire/Explosion Hazard:CONTACT W ALCOHOLS & SOME ORGANICS MAY
CAUSE SPONTANEOUS IGNITION.
================== Accidental Release Measures ==================
Spill Release Procedures:DO NOT TOUCH SPILLED MATERIAL. AVOID INHALING
DUST. SHOVEL INTO PVC/STAINLESS STEEL CONTAINER & COVER. NEUTRALIZE
RESIDUE W SODA ASH & WASH AREA W H*2O.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP DRY(CORROSIVE WHEN WET);KEEP AWAY
FROM ORGANIC AND REDUCING AGENTS. TREAT AS ANY CHROMIC ACID
COMPOUND.
Other Precautions:DO NOT TAKE INTERNALLY, OR INHALE DUSTS OR MIST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DUST MASK
Ventilation:LOCAL EXHAUST TO ELIMINATE DUST/FUMES
Other Protective Equipment:RUBBER APRON & BOOTS.
Supplemental Safety and Health
MFG.BY KELITE PRODUCTS DIV: WILL CORRODE FE,AL,ZN,CU WHEN WET OR SOLN.
================== Physical/Chemical Properties ==================
HCC:D1
Solubility in Water:APPRECIABLE
Appearance and Odor:REDDISH BROWN POWDER, NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID ORGANICS, ALCOHOLS,& ANY REDUCING AGENTS.
Stability Condition to Avoid:ELEVATED TEMPERATURES ABOVE 150F.
Hazardous Decomposition Products:FIRE,ELEVATED TEMPERATURE MAY RELEASE
TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:TREAT AS CHROMIC ACID/HEXAVALENT CHROMIUM. DO
NOT RELEASE TO SEWER OR WATERWAYS. CONTACT SUPPLIER FOR DISPOSAL
METHODS. HANDLE/DISPOSE IN FULL REGULATORY COMPLIANCE
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LYPHOLYTE,MULTI-ELECTROLYTES
Preparer's Name:CHRISTINA J. BARRINGTON
CAGE:39832
CAGE:39832
============= Composition/Information on Ingredients =============
Ingred Name:CALCIUM ACETATE
CAS:62-54-4
RTECS #:AF7525000
Other REC Limits:NONE RECOMMENDED
Ingred Name:MAGNESIUM ACETATE
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM ACETATE
CAS:127-08-2
RTECS #:AJ3325000
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM CHLORIDE
CAS:7447-40-7
RTECS #:TS8050000
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM ACETATE
CAS:126-96-5
RTECS #:AJ4375000
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM GLUCONATE
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY
SYSTEM. ACUTE- THIS PRODUCT IS INTENDED FOR THERAPEUTIC USE ONLY
WHEN PRESCRIBED BY A PHYSICIAN. POTENTIAL ADVERSE REACTIONS FROM
PRESCRIBED DOSES & OVERDOSES ARE DESCRIBED IN PACKAGE INSERT. EYE,
SKIN& RESPIRATORY IRRITATION MAY OCCUR. INGESTION: UNKNOWN.
CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE OF THE INGREDIENTS IN THIS PRODUCT
IS LISTED BY NTP, IARC OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYES, SKIN AND RESPIRATORY TRACT IRRITATION
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH A HISTORY OF SKIN
AND RESPIRATORY DISORDERS MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. EYE/SKIN:FLUSH
WITH WATER FOR 15 MINUTES. KEEP EYELIDS OPEN. REMOVE CONTAMINATED
CLOTHING. INHALATION:REMOVE TO FRESH AIR. PROVIDE CPR/OXYGEN IF
REQUIRED. IN GESTION:FLUSH MOUTH OUT WITH WATER IMMEDIATELY. SEEK
MEDICAL ATTENTION. FOR ADVERSE DRUG REACTION INFORMATION CALL
708-317-5937.
===================== Fire Fighting Measures =====================
Flash Point:>200F,>93C ESTIM
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
NIOSH-APPROVED SELF CONTAINED BREATHING APPARATUS. COOL FIRE
EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
TOXIC FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR RECOMMENDED PERSONAL PROTECTIVE
EQUIPMENT. USE ABSORBENT TOWELS TO CLEAN-UP SPILL. WIPE SURFACES
CLEAN AND WASH WITH SOAP AND WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:WHEN HANDLING PHARMACEUTICAL PRODUCTS,
AVOID ALL CONTACT AND INHALATION OF DUST, FUMES, MIST AND/OR VAPORS
ASSOCIATED WITH THE PRODUCT.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED WITH ADEQUATE
VENTILATION.
Ventilation:GENERAL ROOM VENTILATION IS USUALLY SATISFACTORY. USE LOCAL
EXHAUST VENTILATION WHEN NECESSARY.
Other Protective Equipment:EYE WASH STATION, DISPOSABLE GARMENTS (IF
CONTACT ANTICIPATED)
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
pH:6.6
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR, COLORLESS SOLUTION - ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:FREEZING
Hazardous Decomposition Products:MAY FORM TOXIC FUMES, SMOKE, NOX.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SOLVENT RUG AND UPHOSLTY CLEANER, 843
CAGE:JDMMA
CAGE:JDMMA
============= Composition/Information on Ingredients =============
Ingred Name:ETHANE, 1,1,1-TRICHLORO-; (1,1,1-TRICHLOROEHANE) (SARA
III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 97%
OSHA PEL:350 PPM;450 STEL
ACGIH TLV:350 PPM;450 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: PROLONGED OR REPEATED SKIN
CONTACT CAN CAUSE DERMATITIS. CHRONIC: CAN CUASE HEADACHE, MENTAL
CONFUSION, DEPRESSION, FATIGUE, LOSS OF SENSE OF BALANCE, AND
VISUAL DISTURBANCES. INHAL: MOD IRRIT TO RESP TRACT. SKIN: MILD
IRRIT, PROLONGED/REPEATED CONTACT MAY PRODUCE A BURNING SENS AND
MAY RSLT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: IN DERMATITIS. EYE: MILDLY IRRIT.
INGEST: IF INGESTED IT CAN IRRIT THE GASTRO INTESTINAL TRACT AND
PRODUCE CHEMICAL PNEUMONIA IF ASPIRATED INTO LUNGS. CHLOROCARBON
MATLS HAVE PRODUCED SENSITOF THE MYOCARDIUM TO EPINEPHRINE IN LAB
ANIMALS & COULD HAVE A SIMILAR EFT IN HUMANS. ADRENOMIMETICS (SUPP
DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE: IMMEDIATELY FLUSH WITH WATER FOR AT LEAST 15 MIN. SEEK
MEDICAL ATTENTION. SKIN: WASH AREAS WITH SOAP AND WATER. REMOVE
CONTAMINATED CLOTHING AND WASH BEFORE REUSE. INHAL: GET PERSON TO
FRESH AIR.IF BRTHG HAS STOPPED, ARTF RESP SHLD BE STARTED. OXYGEN
MAY BE ADMINISTERED. SEEK MED ATTN IMMEDIATELY. INGEST: DO NOT
INDUCE VOMITING. SEEK MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CONTENTS UNDER PRESSURE, EXPOSURE TO
TEMPERATURES IN EXCESS OF 130F MAY CAUSE BURSTING. THERMAL
DECOMPOSITION PRODUCTS MAY INCLUDE HCL & PHOSGENE .
================== Accidental Release Measures ==================
Spill Release Procedures:PREPARING WASTE FOR DISPOSAL: REPLACE CAP AND
DISCARD CONTAINER IN TRASH. DO NOT INCINERATE OR PUNCTURE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTENTS UNDER PRESSURE, DO NOT
PUNCTURE INCINERATE, OR THROW INTO FIRE. STORE WHERE TEMPERATURE IS
UNDER 120F.
Other Precautions:PROLONGED EXPOSURE TO SUNLIGHT OR OTHER SOURCE OF
HEAT MAY CAUSE BURSTING. CONTAINS CHLORINATED SOLVENTS. USE ONLY IN
WELL VENTILATED AREA. AVOID PROLONGED BREATHING OF VAPORS OR
CONTACT WITH SKIN. NO SMOKING IN AREA OF USE. DO (SUPP DATA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:USE WITH ADEQUATE VENTILATION, AND LOCAL EXHAUST.
Other Protective Equipment:PLASTIC APRON.
Work Hygienic Practices:TRAIN EMPOLOYEES IN PROPER USE, FOLLOW LABEL
DIRECTIONS.
Supplemental Safety and Health
EFTS OF OVEREXP: (E.G., EPINEPHRINE) MAY BE CONTRAINDICATED EXCEPT FOR
LIFE-SUSTAINING USES IN HUMANS ACUTELY/CHRONICALLY EXPOSED TO
CHLOROCARBONS . OTHER PREC:NOT USE IN THE GENERAL VICINITY OF ARC
WELDING, OPEN FLAMES/HOT SURFACES.HEAT &/OR UV RADIATION MAY CAUSE
THE FORMATION OF HCL &/OR PHOSGENE .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:165F,74C
Melt/Freeze Pt:M.P/F.P Text:-34F,-37C
Vapor Pres:125 @ 20C
Vapor Density:-4.55
Spec Gravity:1.32 (H*2O=1)
Evaporation Rate & Reference:0.37 (BUTYL ACETATE=1)
Solubility in Water:0.07
Appearance and Odor:CLEAR, COLORLESS LIQUID CHLOROFORM LIKE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, ALKALIMETALS, OPEN FLAMES & ELEC ARCS. AVOID USING OR
CONTACT WITH ALUMINUM OR ZINC & THEIR ALLOYS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:AT HIGH TEMPS, DECOMPOSES TO GIVE OFF
HYDROGEN CHLORIDE GAS, & SMALL AMTS OF OTHER TOX VAPS SUCH AS
PHOSGENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ALL WASTES IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: KICK OFF AEROSOL, 5008
Cage: HO204
Box: 152170
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 0A6H9
Box: 152170
Cage: HO204
Box: 152170
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: SEE INGREDIENT 1.
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:MILDLY IRRITATING TO EYES, NOSE & THROAT. SKIN
CONTACT MAY PRODUCE A DRY, SCALY TISSUED SKIN. INHALATION CAN LEAD TO
DIZZINESS, WEAKNESS, NAUSEA & POSSIBLE UNCONSCIOUSNESS, EVEN
ASPHYXIATION. CH RONIC:IRRITATING TO SKIN & EYES. CONTINUOUS EXPOSURE TO
VAPORS WILL LEAD TO UNCONSCIOUSNESS & EVEN (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:ASPHYXIATION. CENTRAL NERVOUS
SYSTEM DEPRESSANT.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL:REMOVE FROM AREA TO FRESH AIR. IF NOT BRTHG, CLEAR AIRWAY
& START MOUTH-TO-MOUTH ARTF RESP. GET IMMED MED ATTN. EYE:RINSE W/WATER.
REMOVE ANY CONT LENSES & CONTINUE FLUSHING W/PLENTY OF WATER FO R SEVERAL
MINS (AT LST 15 MINS). SEEK MED ATTN IF IRRIT DEVELOPS. SKIN:WASH AFFECTED
AREAS W/PLENTY OF SOAP & WATER FOR SEVERAL MINS. SEEK MED ATTN IF IRRIT
DEVELOPS. INGEST:GIVE 3-4 GLASSES (SUPDAT)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: OPEN ALL VENTS, DOORS & WINDOWS. EXTINGUISH ALL
OPEN FLAMES. DO NOT OPEN OR CLOSE A SWITCH. MOP UP & PUT RAGS IN AN OPEN
CAN OUT DOORS.
Waste Disposal Methods: DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS (FP N). DISPOSE ACCORDING TO CITY, STATE & EPA GUIDELINES. DO
NOT INCINERATE.
Handling And Storage Precautions: KEEP AWAY FROM HEAT OR OPEN FLAMES. STORAGE
TEMPERATURE:80F(MAX), 32F(MIN). STORE INDOORS. KEEP REFRIGERATED.
Other Precautions: FOLLOW LABEL DIRECTION. KEEP OUT OF REACH OF CHILDREN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: COC
Flash Point Text: -58F,-50C
Lower Limits: 1.85%
Upper Limits: 48%
Extinguishing Media: FOAM, "ALCOHOL" FOAM, CO*2, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). USE WATER IN FINE SPRAY TO COOL UNBROKEN CNTNRS TO PREVENT
BURSTING FROM EXCESSIVE PRESSURE.
Unusual Fire/Explosion Hazard: EXTREMELY FLAMMABLE. FIRE FIGHTING SHOULD BE
DONE FROM UPWIND TO MINIMIZE POSSIBILITY OF EXPOSURE TO PRODUCT, SMOKE &
FUMES. EVACUATE PEOPLE DOWNWIND AS APPROP.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N). TYPICAL USE OF THIS PRODUCT DOES NOT REQUIRE SPECIAL
RESPIRATORY PROTECTION.
Ventilation: WORK PLACE SHOULD BE PROVIDED W/ADEQUATE VENTILATION TO MAINTAIN
AIR CONCENTRATION BELOW TLV.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: NOTE:USERS OF "L" VERSION SHOULD CONSULT "LR"
VERSION FOR ADDITIONAL INFORMATION (FP N). FIRST AID PROC:OF WATER, BUT DO
NOT INDUCE VOMITING. IF VOMITING OCCURS, GIVE FLUIDS AGAIN. GET IMMEDIATE
MEDIC AL ATTENTION.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 94.0F,34.4C
Vapor Pres: 80
Vapor Density: 2.58
Spec Gravity: 0.7135 (H*2O=1)
Evaporation Rate & Reference: 4 (BUTYL ACETATE=1)
Solubility in Water: SLIGHT
Appearance and Odor: NON-VISCOUS, COLORLESS, TRANSPARENT; ETHER ODOR.
Percent Volatiles by Volume: 89
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: REACTS VIGOROUSLY W/ACETYL PEROXIDE IN AIR & BROMOAZIDE.
Hazardous Decomposition Products: NONE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: KICK OFF AEROSOL, 5008
Cage: HO204
Assigned IND: Y
Company Name: MANTEK DIV NCH CORP
Street: UNKNOWN
PO Box: 152170
Zipcode: 75015
Label Required IND: Y
Date Of Label Review: 07/13/1995
Status Code: C
Label Date: 07/13/1995
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: ACUTE:MILDLY IRRITATING TO EYES, NOSE & THROAT.
SKIN CONTACT MAY PRODUCE A DRY, SCALY TISSUED SKIN. INHALATION CAN LEAD TO
DIZZINESS, WEAKNESS, NAUSEA & POSSIBLE UNCONSCIOUSNESS, EVEN
ASPHYXIATION. CH RONIC:IRRITATING TO SKIN & EYES. CONTINUOUS EXPOSURE TO
VAPORS WILL LEAD TO UNCONSCIOUSNESS & EVEN ASPHYXIATION. CENTRAL NERVOUS
SYSTEM DEPRESSANT.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MAGNESIUM NITRATE,HEXAHYDRATE,75450
Preparer's Name:ALEXANDER A. PICCIRILLI
CAGE:6U218
CAGE:6U218
============= Composition/Information on Ingredients =============
Ingred Name:MAGNESIUM NITRATE,HEXAHYDRATE
CAS:13446-18-9
RTECS #:OM3756000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS UNKNOWN.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY
& GI TRACTS. ACUTE- DANGER! STRONG OXIDIZER. HARMFUL IF SWALLOWED.
MAY CAUSE EYES IRRITATION. CONCENTRATED AQUEOUS SOLUTION/DUST MAY
CAUSE SKIN IRRITATION. INHALA TION OF DUST/MISTS MAY CAUSE LOCAL
IRRITATION. INGESTION MAY SHOW CYANOSIS (BLUE SKIN), DIZZINESS.
CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, PAIN, BLUE SKIN, COUGHING,
DIZZINESS, HEADACHE
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION MAY BE
MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:CALL A DOCTOR IF SYMPTOMS PERSIST. EYE:IMMEDIATELY FLUSH WITH
WATER FOR 15 MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP &
WATER. INHALED:REMOVE TO FRESH AIR. PROVIDE CPR/OXYGEN IF NEEDED.
ORAL:I F CONSCIOUS, DRINK 1-2 GLASSES OF WATER& INDUCE VOMITING.
REPEAT UNTIL VOMIT FLUID IS CLEAR. CALL A PHYSICIAN/POISON CONTROL
CENTER IMMEDIATELY. NEVER GIVE FLUID/INDUCE VOMITING IF
UNCONSCIOUS.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE OR DRY CHEMICAL. USE
WATER SPRAY TO COOL FIRE EXPOSED CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:STRONG OXIDIZER! CONTACT WITH OTHER
MATERIALS MAY CAUSE FIRE. GREATLY INCREASES BURNING RATE OF
COMBUSTIBLE MATERIALS. MAY FORM HAZARDOUS DECOMPOSITION PRODUCTS
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP SPILL. AVOID CREATING DUST. PLACE
SPILL IN APPROPRIATE CONTAINER FOR RECYCLING OR WASTE DISPOSAL.
VENTILATE AREA AND WASH SPILL SITE WITH WATER. FLUSH TO SEWER WITH
LARGE AMOUNT OF WATER, IF PERMITTED.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE AWAY FROM
COMBUSTIBLE MATERIALS. KEEP CONTAINER TIGHTLY CLOSED. USE IN WELL
VENTILATED AREA.
Other Precautions:DO NOT RAISE DUST. AVOID CONTACT WITH EYES, SKIN OR
CLOTHING. AVOID INHALATION OF DUST. WASH THOROUGHLY AFTER HANDLING
MATERIAL. KEEP OUT OF REACH OF CHILDREN. DO NOT INGEST. FOR
LABORATORY USE ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. IF AIRBORNE
CONCENTRATION IS HIGH, WORK IN VENTILATION HOOD OR WEAR A
NIOSH-APPROVED DUST RESPIRATOR OR DUST MASK.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
FUME OR DUST LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER, PROTECTIVE
CLOTHING AND/OR UNIFORM
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:D1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:DECOMPOSES
Melt/Freeze Pt:M.P/F.P Text:203F,95C
Decomp Temp:Decomp Text:626F,330C
Spec Gravity:1.464
Viscosity:NOT RELEVANT
Evaporation Rate & Reference:NOT RELEVANT
Solubility in Water:44% @ 68F (20C)
Appearance and Odor:WHITE OR COLORLESS CRYSTALS - NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REDUCING AGENTS, OXIDIZABLE AND COMBUSTIBLE MATERIALS, ALUMINUM
POWDER/DUST, CYANIDES
Stability Condition to Avoid:EXCESSIVE HEAT (TEMPERATURES ABOVE 626
F/330C)
Hazardous Decomposition Products:NITRIC ACID GASES, NITROGEN OXIDES AND
OTHER HAZARDOUS DECOMPOSITION PRODUCTS MAY BE FORMED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. DISPOSE OF IN A SANITARY LANDFILL OR
CONTRACT WITH A LICENSED WASTE DISPOSAL SERVICE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BETZ ENTEC 367
CAGE:FO446
CAGE:FO446
CAGE:57394
============= Composition/Information on Ingredients =============
Ingred Name:1-BROMO-3-CHLORO-5, 5 DIMETHYLHYDANTOIN
CAS:16079-88-2
RTECS #:MI9195400
OSHA PEL:NONE
ACGIH TLV:NONE
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION/CORROSIVE.
INHALATION: IRRITATION TO UPER RESPIRATORY TRACT, NOSE/THROAT.
SKIN: IRRITATION, TISSUE NECROSIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION/CORROSIVE. INHALATION:
IRRITATIONTO UPPER RESPIRATORY TRACT, NOSE/THROAT. SKIN:
IRRITATION, TISSUE NECROSIS.
======================= First Aid Measures =======================
First Aid:SKIN: REMOVE/WASH CLOTHING BEFORE REUSE. WASH AREA W/LARGE
AMOUNTS OF SOAP SOLUTION OR WATER FOR 15 MIN. CONTACT PHYSICAN.
EYES: FLUSH W/WATER FOR 15 MIN. CONTACT PHYSICIAN. INHALATION:
REMOVE VICTIM FROM CONTAMINATED AREA. CONTACT PHYSICIAN.
INGESTION: DON'T FEED ANYTHING BY MOUTH TO AN UNCONSCIOUS OR
CONVULSIVE. DON'T INDUCE VOMITING. DILUTE CONTENTS OF STOMACH USING
3-4 GLASSES MILK OR WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, FOAM, WATER
Fire Fighting Procedures:WEAR POSITIVE PRESSURE SELF-CONTAINED
BREATHING APPARATUS, FULL FACE-PIECE TYPE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA, USE SPECIFIED PROTECTIVE
EQUIPMENT. SPILL MATERIAL WHICH CAN'T BE RECOVERED FOR RE-USE
SHOULD BE PLACED IN A WASTE DISPOSAL CONTAINER & DISPOSED OF IN AN
APPROVED PESTICIDE LANDFILL.
Neutralizing Agent:3% HYDROGEN PEROXIDE SOLUTION.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP DRUMS & PAILS CLOSED WHEN NOT IN
USE. KEEP, DRY. AVOID MOISTURE. DON'T STORE AT ELEVATED TEMPS.
STORE AWAY FROM OXIDIZABLE/COMBUSTIBLE MATERIALS.
Other Precautions:REMOVE CONTAMINATED CLOTHING, WASH BEFORE REUSE
OXIDIZER. AVOID ALL CONTACT WITH REDUCING AGENTS, OIL, GREASES,
ORGANICS & ACIDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF >TLV, USE RESPIRATOR W/ACID GASES CARTRIDGES
& DUST/MIST PREFILTERS.
Ventilation:ADEQUATE VENTILATION TO KEEP <TLV FOR NUISANCE OR INERT
DUSTS.
Other Protective Equipment:CHEMICAL RESISTANT APRON
Work Hygienic Practices:REMOVE/WASH CONTAMINATED CLOTHING BEFORE REUSE.
WASH OFF AFTER EACH USE. REPLACE AS NECESSARY.
Supplemental Safety and Health
RCRA D002 CORROSIVE, D003 REACTIVE
================== Physical/Chemical Properties ==================
Spec Gravity:60
pH:5%
Solubility in Water:0.2%
Appearance and Odor:WHITE, HALOGEN ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REDUCING AGENTS, OILS, GREASES, ORGANICS & ACIDS.
Stability Condition to Avoid:MOISTURE. DON'T STORE AT ELEVATED
TEMPERATURES.
Hazardous Decomposition Products:ELEMENTAL OXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:WATER CONTAMINATED W/THIS PRODUCT MAY BE SENT TO
A SANITARY SEWER TREATMENT FACILITY, IN ACCORDANCE W/ANY LOCAL
AGREEMENT. A PERMITTED WASTE TREATMENT FACILITY OR DISCHARGED UNDER
A NPDES PERMIT PRODU CT. BURY IN AN APPROVED PESTICIDE FACILITY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DAP WELDWOOD CARPENTER'S GLUE
CAGE:90300
CAGE:90300
============= Composition/Information on Ingredients =============
Ingred Name:BUTYL BENZYL PHTHALATE, BBP, BENZYL BUTYL PHTHALATE
1,2-BENZENEDICARBOXYLIC ACID, BUTYL PHENYLMETHYL ESTER
CAS:85-68-7
RTECS #:TH9990000
Fraction by Wt: 1-3%
Other REC Limits:5 MG/CUM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:VINYL ACETATE
CAS:108-05-4
RTECS #:AK0875000
Fraction by Wt: <0.5%
Other REC Limits:10 PPM
ACGIH TLV:35 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VOL ORGANIC CMPD: LESS WATER LESS EXEMPT SOLVENT-27 G/L;
MATERIAL - 11 G/L
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY IRRITATE EYES, SKIN, NOSE &
RESPIRATORY TRACT. VINYL ACETATE MONOMER MAY CAUSE SKIN, EYE, &
UPPER RESPIRATORY TRACT IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:MAY IRRITATE EYES, SKIN, NOSE & RESPIRATORY
TRACT. VINYL ACETATE MONOMER MAY CAUSE SKIN, EYE & UPPER
RESPIRATORY TRACT IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LARGE AMOUNTS OF WATER FOR 15 MINS. SKIN: WASH
W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION: DON'T
INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>200F
Extinguishing Media:FOAM, WATER, DRY CHEMICALS
Fire Fighting Procedures:USE WATER SPRAY TO COOL EXPOSED SURFACES.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE SPILL AREA. USE ABSORBENT MATERIAL/SCRAPE
UP DRIED MATERIAL & PLACE INTO CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T REUSE EMPTY CONTAINERS. STORE
AWAY FROM CAUSTICS & OXIDIZERS. KEEP CONTANERS AWAY FROM EXCSSIVE
HEAT & FREEZING.
Other Precautions:KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. DON'T
TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED
Ventilation:NORMAL ROOM
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Vapor Pres:17.5
Vapor Density:<1
Spec Gravity:1.08
Evaporation Rate & Reference:(WATER=1): 1
Solubility in Water:MISCIBLE
Appearance and Odor:THICK WHITE LIQUID W/SLIGHT ODOR
Percent Volatiles by Volume:45
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS & CAUSTICS
Stability Condition to Avoid:EXCESSIVE HEAT, FREEZING
Hazardous Decomposition Products:OXIDES OF CARBON & NITROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:LIQUIDS CAN'T BE DISPOSED OF IN A LANDFILL.
DISPOSE OF IAW/LOCAL, STATE & FEDERAL REGUALTIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TT-L-32A, BLUE, 15044, LACQUER
Preparer's Name:BJG
CAGE:DO292
CAGE:DO292
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III) (VAPOR PRESSURE 4.2 MM HG @ 68F)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 14%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:50 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL ETHYL KETONE (SARA III) (VAPOR PRESSURE 70 MM HG @
68F)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 12%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM
ACGIH TLV:200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPYL ALCOHOL (VAPOR PRESSURE 33 MM HG @ 68F)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 9%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
Ingred Name:XYLENE (SARA III) (VAPOR PRESSURE 4.2 MM HG @ 68F)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL ACETATE
CAS:141-78-6
RTECS #:AH5425000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VOC: 532 GRAMS/LITER (4.44 LBS/GAL)
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: NASAL & RESP IRRIT, DIZZINESS,
FATIGUE, NAUSEA, HEADACHE, UNCONSCIOUS, ASPHYXIATION. SKIN:
PROLONGED/REPEATED: IRRITATION. ABSORPTION: POTENTIAL HAZARD. EYES:
SEVERE IRRIT, REDNESS, TEARING, BL URRED VISION. INGEST: GI
IRRITATION, NAUSEA, VOMITING, DIARRHEA, ASPIRATION INTO LUNGS CAN
CAUSE CHEMICAL PNEUMONITIS.
Effects of Overexposure:ACUTE: IRRITATION OF SKIN, EYES, MUCOUS
MEMBRANES, DRYING, DEFATTING OF SKIN. AVOID INGESTION AND BREATHING
OF VAPORS. CHRONIC: EYE, LIVER, KIDNEY, AND CENTRAL NERVOUS SYSTEM
DAMAGE MAY OCCUR.
Medical Cond Aggravated by Exposure:MAY PROVOKE ASTHMATIC RESPONSE IN
PERSON WITH ASTHMA WHO ARE SENSITIVE TO AIRWAY IRRITANT.
======================= First Aid Measures =======================
First Aid:IF SPILLED ON THE SKIN OR IN THE EYE, WASH WITH COPIOUS
QUANTITIES OF WATER, CONTACT PHYSICIAN IF SPILLED IN THE EYE(S). IF
INGESTED, DO NOT INDUCE VOMITING, KEEP PERSON WARM, QUIET AND
CONTACT PHYSIC IAN. BREATHING: REMOVE PERSON TO FRESH AIR. GIVE
OXYGEN IF BREATHING DIFFICULT; GIVE ARTIFICIAL RESPIRATION IF
BREATHING STOPS. KEEP PERSON WARM AND GET MEDICAL HELP.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>24F,>-4C
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS WITH A
FULL FACE PIECE OPERATED IN PRESSURE DEMAND OR OTHER POSITIVE
PRESSURE MODE WHEN FIGHTING FIRES.
Unusual Fire/Explosion Hazard:VAPOR HEAVIER THAN AIR MAY TRAVEL ALONG
GROUND OR BE MOVED BY VENT & IGNITED BY HEAT, PILOT LIGHTS, FLAME &
IGNITION SOURCES AT LOCATIONS DISTANT FROM SOURCE.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE UP AND CONTAIN SPILL WITH INERT MATERIAL,
MOP UP & PLACE MATERIAL INTO CONTAINERS. PREVENT RUN-OFF TO SEWER,
STREAMS. NOTIFY AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE OR USE IN HIGH TEMPERATURE
AREAS, SPARKS, FLAME. KEEP CLOSURE TIGHT & CONTAINER UPRIGHT TO
PREVENT LEAK. STORE IN VENTED AREA.
Other Precautions:AVOID CONTACT WITH OR BREATHING OF VAPORS RELEASED
DURING CURING PROCESS. DO NOT TAKE INTERNALLY. AVOID CONTACT WITH
SKIN & EYES. AVOID BREATHING OF VAPOR & MIST. ALL HAZARD
PRECAUTIONS GIVEN IN MSDS MUST BE OBSERVED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ABOVE TLV, NIOSH/MSHA AIR SUPPLIED RESPIRATOR
ADVISED IN ABSENCE OF ENVIRONMENTAL CONTROL. OSHA REGS ALSO PERMIT
OTHER NIOSH/MSHA RESPIRATORS UNDER SPECIFIED CONDITIONS (SEE SFTY
EQUIP SUPPLIER).IM PLEMENT ENGINEER/ADMINISTRATIVE CONTROLS
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING AND BOOTS.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
WASHROOM.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:175 TO 314F
Vapor Density:> AIR
Spec Gravity:0.99 (WATER=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NOT SOLUBLE
Appearance and Odor:BLUE VISCOUS LIQUIDS WITH LACQUER SOLVENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NEVER USE WELDING OR CUTTING TORCH ON/NEAR
DRUMS (EVEN EMPTY) BECAUSE PRODUCT (EVEN RESIDUE) CAN IGNITE
EXPLOSIVELY.
==================== Disposal Considerations ====================
Waste Disposal Methods:SMALL: ALLOW VOLATILE PART TO EVAPORATE IN HOOD.
ALLOW TIME TO COMPLETELY CLEAR HOOD DUCTS. DISPOSE OF REMAINING
MAT'L IN ACCORD W/REGS. LRG: DESTROY BY LIQ INCINERATION. CONTAM
ABSORB MAY BE DEPOSITE D IN LANDFILL IN ACCORD W/LOCAL, STATE,FED
REGS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:RNEASY PLANT MINI KIT,74906
CAGE:01QTQ
CAGE:01QTQ
============= Composition/Information on Ingredients =============
Ingred Name:GUANIDINE THIOCYANATE
CAS:593-84-0
RTECS #:XL1225000
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF SWALLOWED, INHALED, OR
ABSORBED THROUGH SKIN. MATERIAL IS DESTRUCTIVE TO TISSUE OF MUCOUS
MEMBRANES AND UPPER RESPIRATORY TRACT. CONTACT WITH ACIDS LIBERATES
VERY TOXIC GAS. ACUTE: INHALATI ON: MAY BE HARMFUL BY INHALATION.
MATERIAL IS DESTRUCTIVE TO MUCOUS MEMBRANES AND UPPER RESPIRATORY
TRACT. EYE CONTACT: CAUSES EYE IRRITATION. SKIN CONTACT: CAUSES
SKIN IRRITATION, HARMFUL BY SKIN ABS ORPTION. INGESTION: HARMFUL IF
SWALLOWED. CHRONIC: NOT APPLICABLE.
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:EYE: IMMEDIATELY FLUSH EYES WITH COPIOUS AMOUNTS OF WATER FOR
AT LEAST 15 MINUTES. ASSURE ADEQUATE FLUSHING OF THE EYES BY
SEPARATING THE EYELIDS WITH FINGERS. SKIN: IMMEDIATELY WASH SKIN
WITH SOAP AN D COPIOUS AMOUNTS OF WATER. INHALATION: REMOVE TO
FRESH AIR. IF NOT BREATHING GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. INGESTION: WASH OUT MOUTH WITH
WATER PROVIDED PERSON IS CONSCIOUS. CALL A PHYSICIAN. REMOVE AND
WASH CONTAMINATED CLOTHING PROMPTLY.
===================== Fire Fighting Measures =====================
Flash Point:=58.C, 136.4F
Extinguishing Media:NONCOMBUSTIBLE. USE EXTINGUISHING MEDIA APPROPRIATE
TO SURROUNDING FIRE CONDITIONS.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
================== Accidental Release Measures ==================
Spill Release Procedures:PRECAUTIONARY MEASURES: WEAR NIOSH APPROVED
VERMICULITE AND PLACE IN CLOSED C ONTAINERS FOR DISPOSAL. VENTILATE
AREA AND WASH SPILL SITE AFTER MATERIAL PICKUP IS COMPLETE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE: STORE TIGHTLY CLOSED AT
20-25C.
Other Precautions:KEEP TIGHTLY CLOSED. DO NOT GET IN EYES, ON SKIN, OR
ON CLOTHING. DO NOT BREATHE VAPOR. SEVERE EYE IRRITANT. STORE IN A
COOL DRY PLACE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:EYE WASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
WASTE DISP METH: UNLESS SPECIFIED DIFFERENTLY, NONCONTAMINATED
PACKAGING MAY BE TREATED LIKE HOUSEHOLD WASTE/RECYCLED.
================== Physical/Chemical Properties ==================
Spec Gravity:1.160 G/CM3 @ 20C
pH:7.0 @ 20C
Solubility in Water:SOLUBLE
Appearance and Odor:COLORLESS LIQUID; NONE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:TOXIC FUMES OF CARBON MONOXIDE, CARBON
DIOXIDE, NITROGEN OXIDES, AND HYDROGEN CYANIDE.
=================== Toxicological Information===================
Toxicological Information:IPR-MUS LD50: 300 MG/KG NTIS** AD277-689.
ONLY SELECTED REGISTRY OF TOXIC EFFECTS OF CHEMICAL SUBSTANCE
(RTECS) DATA IS PRESENTED HERE. SEE ACTUAL ENTRY IN RTECS FOR
COMPLETE INFORMATION. CAUTION - SU BSTANCES NOT YET FULLY TESTED.
ADDITIONAL INFORMATION; CONTACT WITH ACIDS LIBERATES VERY TOXIC
GAS. THE PRODUCT SHOULD BE HANDLED WITH THE NORMAL CAUTION ACCORDED
CHEMICALS. ADDITIONAL HARMFUL PROPER TIES CANNOT BE RULED OUT.
===================== Ecological Information =====================
Ecological:NOT APPLICABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:THERE ARE NO UNIFORM REGS FOR DISP OF CHEM/
RESIDUES. CHEM RESIDUES GENERALLY COUNT AS SPECIAL WASTE. WE REC
THAT YOU CONTACT EITHER AUTHORITIES IN CHARGE/APPRVD WASTE DISP
COMPANIES WHICH WILL ADVISE YOU ON HOW TO DISPOSE OF SPECIAL
WASTE. HANDLE CONTAMD PACKAGING IN SAME WAY AS SUBSTANCE ITSELF. (
SUPDAT)
=================== MSDS Transport Information ===================
Transport Information:NOT APPLICABLE.
===================== Regulatory Information =====================
Federal Regulatory Information:REGULATORY INFORMATION: LABELING: XN,
HARMFUL, R 20/21/22-32.
State Regulatory Information:
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LO-PERM LATEX WALL PRIMER, 969-100 WHITE
Preparer's Name:JULIAN SHAFFER
CAGE:0Y837
CAGE:0Y837
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS; (CONTAINS PIGMENTS ING # 2-4)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9495
Ingred Name:SILICATES
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:CALCIUM CARBONATE (MARBLE) (LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9495
Ingred Name:4-ISOTHIAZOLIN-3-ONE, 5-CHLORO-2-METHYL (PAINT
PRESERVATIVE)
CAS:26172-55-4
RTECS #:NX8156850
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: DIZZINESS, HEADACHE, NAUSEA,
CONFUSION, IRRITATION TO UPPER RESPIRATORY TRACT, UNCONSCIOUSNESS,
SKIN & EYE IRRITATION. CHRONIC: NONE KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARD.
Medical Cond Aggravated by Exposure:NONE KNOWN. SEE YOUR PHYSICIAN FOR
SPECIFIC MEDICAL OPINION REGARDING YOUR CONDITION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING, CONSULT
PHYSICIAN. EYE CONTACT: FLUSH WITH LARGE VOLUMES OF WATER FOR AT
LEAST 15 MINUTES. SKIN CONTACT: WIPE OFF WITH A RAG, WASH
THOROUGHLY WITH S OAP AND WATER. INGESTION: CONSULT HOSPITAL
EMERGENCY ROOM OR POISON CONTROL CENTER IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO THE
BUILD-UP OF STEAM PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA TO PREVENT BUILD-UP OF VAPORS.
FOR SMALL SPILLS, SOAK UP WITH ABSORBANT. FOR LARGER SPILLS, DIKE
AREA, WITH ABSORBENT MATERIAL AND SCOOP UP LIQUIDS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE UPRIGHT IN SEALED CONTAINERS
AWAY FROM HEAT AND FLAME.
Other Precautions:REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A PARTICLE MASK (NIOSH, TC-21C) TO AVOID
BRTHG SPRAY MIST/SANDING DUST IF (LOCAL) VENT IS ADEQUATE TO KEEP
VAP CONCENTRATIONS W/IN ACCEPTABLE (TLV) LIMITS. IF LOCAL VENT IS
NOT SUFFICIENT/WHERE EX POS LIMITS ARE EXCEEDED, (SUPDAT)
Ventilation:LOCAL CROSS-VENTILATION/MECHANICAL EXHAUST SUFFICIENT TO
KEEP ALL HAZARDOUS VAPOR CONCENTRATION BELOW PRESCRIBED LIMITS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
RESP PROT:WEAR A SUITABLE, PROPERLY FITTED RESPIRATOR (NIOSH TC-23C OR
BETTER) FOR ORGANIC VAPORS WITH A DUST FILTER AS NEEDED.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Density:LTR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:58-62
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO DECOMPOSITION AS IN WELDING.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARD IN LAND FILL IN SEALED METAL CONTAINERS
AWAY FROM HEAT AND FLAME AND IN ACCORDANCE WITH FEDERAL, STATE, AND
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LYMAN CRT WIPE, C-43
Preparer's Name:JOHN J CORLEY
CAGE:04WH1
CAGE:04WH1
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPYL ALCOHOL (SARA 313)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 91%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM/500STEL
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION:HEADACHE, DIZZINESS, NAUSEA,
COMA. SKIN:DRYNESS. INHALATION:HEADACHE, DIZZINESS, NAUSEA.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGESTION:CONSULT PHYSICIAN. SKIN:RINSE WITH WATER.
EYES:FLUSH WITH WATER FOR AT LEAST 15 MINUTES. INHALATION:REMOVE TO
FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:77.0F,25.0C
Lower Limits:2%
Upper Limits:12%
Extinguishing Media:WATER, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM OXIDIZERS, FLAME,
IGNITION SOURCES.
Other Precautions:NOT APPLICABLE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NOT REQUIRED.
Ventilation:LOCAL EXHAUST:MAY BE NEEDED. MECHANICAL (GENERAL):USE IN
WELL VENTILATED AREA.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:178F,81C
Vapor Pres:34
Vapor Density:2.1
Spec Gravity:0.871 (H*2O=1)
Evaporation Rate & Reference:2.9 (BUTYL ACETATE=1)
Solubility in Water:SOLUBLE
Appearance and Odor:COLORLESS LIQUID, ON A TOWELETTE; MEDICINAL ALCOHOL
ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS.
Stability Condition to Avoid:FLAME, IGNITION SOURCES.
Hazardous Decomposition Products:CO, CO*2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . INCINERATION OR EVAPORATE AND LANDFILL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PERCHLOROETHYLENE
Resp. Party Other MSDS Num.:PRODUCT ID #: 02113
CAGE:UO210
CAGE:UO210
Contract Num:SP0450-01-M-D545
CAGE:1KH20
============= Composition/Information on Ingredients =============
Ingred Name:PERCHLOROETHYLENE
CAS:127-18-4
RTECS #:KX3850000
= Wt:100.
OSHA PEL:SEE TABLE Z-2
ACGIH TLV:170 MG/M3;25 PPM
ACGIH STEL:685 MG/M3;100 PPM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50, ORAL, RAT = 2629 MG/KG
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SKIN: CONTACT WITH THE SKIN MAY CAUSE
IRRITATION. THIS PRODUCT MAY BE ABSORBED THROUGH THE SKIN.
PROLONGED OR REPEATED SKIN CONTACT CAN CAUSE DERMATITIS. EYE:
CONTACT WITH THE EYES MAY CAUSE IRRITATIO N. INGESTION: SHORT TERM
EXPOSURE MAY CAUSE DIGESTIVE DISORDERS. INGESTION MAY PRODUCE
SYMPTOMS SIMILAR TO INHALATION. ASPIRATION MAY OCCUR DURING
SWALLOWING OR VOMITING RESULTING IN LUNG DAMAGE. INHA LATION:
INHALATION MAY CAUSE IRRITATION. REPEATED EXPOSURE OF THIS PRODUCT
MAY CAUSE CANCER. OTHER: MAY RESULT IN KIDNEY AND LIVER DAMAGE. MAY
CAUSE CENTRAL NERVOUS SYSTEM DEPRESSION
Explanation of Carcinogenicity:COMPONENTS FOUND ON ONE OF THE OSHA
DESIGNATED CARCINOGEN LISTS ARE: PERCHLOROETHYLENE: NTP=YES,
IARC=YES, OSHA=NO.
Effects of Overexposure:INHALATION: INHALATION MAY CAUSE IRRITATION,
NAUSEA, VOMITING, STOMCAH PAIN, HEADACHE, DROWSINESS, DRUNKENNESS,
VISUAL DISTURBANCES, TINGLING SENSATION, MENSTRUAL DISORDERS,
REPRODUCTIVE EFFECTS, CONV ULSIONS, TREMORS, SEIZURES, COMA,
RESPIRATORY ARREST AND SUDDEN DEATH. MAY ALSO CAUSE ANEMIA AND
IRREGULAR HEART RHYTHM.
Medical Cond Aggravated by Exposure:PREEXISTING EYE DISORDERS, SKIN
DISORDERS, RESPIRATORY (ASTHMA-LIKE) DISORDERS, KIDNEY DISORDERS,
LIVER DISORDERS, NERVOUS SYSTEM AND/OR PULMONARY DISORDERS.
======================= First Aid Measures =======================
First Aid:SKIN: REMOVE CONTAMINATED CLOTHING AND SHOES. WASH EXPOSED
AREAS WITH SOAP AND WATER. CALL A PHYSICIAN IF IRRITATION PERSISTS.
EYE: FLUSH EYES WITH WATER FOR AT LEAST 15 MINS. GET IMMEDIATE
MEDICAL AT TENTION. INGESTION: CALL A PHYSICIAN IMMEDIATELY! DO NOT
INDUCE VOMITING. GIVE 1 - 2 GLASSES OF WATER TO DILUTE. IF VOMITING
OCCURS SPONTANEOUSLY, KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION OF
LIQUID INTO THE LUNGS. DO NOT GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. INHALATION: REMOVE TO FRESH AIR. IF BREATHING
HAS STOPPED, GIVE ARTIFICIAL RESPIRATION. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Autoignition Temp:Autoignition Temp Text:N/AP
Lower Limits:N/AP
Upper Limits:N/AP
Extinguishing Media:USE WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, OR
FOAM.
Fire Fighting Procedures:USE NIOSH-APPROVED SELF CONTAINED BREATHING
APPARATUS AND COMPLETE PROTECTIVE CLOTHING WHEN FIGHTING CHEMICAL
FIRES.
Unusual Fire/Explosion Hazard:HEATING MAY RESULT IN RELEASE OF TOXIC
FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:THIS MATERIAL IS A WATER POLLUTANT & SHOULD BE
PREVENTED FROM CONTAMINATING SOIL OR ENTERING SEWAGE & DRAIN
SYSTEMS OR BODIES OF WATER. EVACUATE AREA & VENTILATE. AVOID
BREATHING VAPORS. CLEAN UP AREA , WEARING PROTECTIVE EQUIPMENT, BY
MOPPING OR WITH ABSORBENT MATERIAL & PLACE IN CLOSED CONTAINERS FOR
DISPOSAL. DO NOT FLUSH TO SEWER. LARGE SPILLS: SEE OTHER
INFORMATION.
Neutralizing Agent:NO DATA PROVIDED BY MANUFACTURER
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLING: AVOID CONTACT WITH SKIN,
EYES, AND CLOTHING. AVOID BREATHING PRODUCT VAPORS AND MISTS. DO
NOT TAKE INTERNALLY. WASH THOROUGHLY AFTER HANDLING THIS MATERIAL.
USE THIS MATERIAL ONLY WITH ADEQU ATE VENTILATION. STORAGE: KEEP
CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:THIS MATERIAL SHOULD BE STORED AT MODERATE
TEMPERATURES. KEEP AWAY FROM HEAT, SPARKS AND OPEN FLAMES. DO NOT
FLAME CUT, BRAZE, OR WELD CONTAINER. THE EMPTY CONTAINER IS
HAZARDOUS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS DO NOT MAINTAIN AIRBORNE
CONCENTRATIONS BELOW RECOMMENDED LIMITS, USE A NIOSH-APPROVED
RESPIRATOR FOR ORGANIC VAPORS.
Ventilation:GOOD GENERAL VENTILATION ( VENTILATION RATES SHOULD BE
MATCHED TO CONDITIONS). USE PROCESS ENCLOSURES, LOCAL EXHAUST TO
MAINTAIN EXPOSURES BELOW EXPOSURE LIMITS
Other Protective Equipment:EMERGENCY SHOWERS, EYE-WASH STATIONS, AND
FIRE BLANKETS SHOULD BE ACCESSIBLE. WEAR PROTECTIVE CLOTHING.
Work Hygienic Practices:NO DATA PROVIDED BY MANUFACTURER.
Supplemental Safety and Health
NOTES TO PHYSICIAN: NEVER ADMINISTER ADRENALINE FOLLOWING EXPOSURE TO
CHLORINATED HYDROCARBONS. INCREASED SENSITIVITY OF THE HEART TO
ADRENALINE MAY BE CAUSED BY OVEREXPOSURE TO CHLORINATED HYDROCARBO
NS.
================== Physical/Chemical Properties ==================
HCC:T4
Boiling Pt:=121.C, 249.8F
Melt/Freeze Pt:=-22.3C, -8.1F
Vapor Pres:14.2 MMHG @ 20 DEG C
Vapor Density:5.83
Spec Gravity:1.6 @ 20 C
pH:6.8-8.4 @ 23 C
Evaporation Rate & Reference:0.09 (BUTYL ACTEATE=1)
Solubility in Water:0.015% @ 25 DEG C
Appearance and Odor:LIQUID, CLEAR, COLORLESSS, VOLATILE, SWEET,
ETHER-LIKE ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, METALS, ACIDS, COMBUSTIBLE MATERIALS, BASES
Stability Condition to Avoid:KEEP AWAY FROM HEAT, SPARKS, AND OPEN
FLAMES
Hazardous Decomposition Products:TOXIC OXIDES OF CARBON, HYDROGEN
CHLORIDE, PHOSGENE, HALOGENATED COMPOUNDS,
Conditions to Avoid Polymerization:WILL NOT OCCUR
=================== Toxicological Information===================
Toxicological Information:MODERATELY TOXIC: INGESTION. IRRIATNT:
INHALATION, SKIN, EYE. IRRITATION DATA: 810 MG/24
HR(S)-SKIN-RABBIT-SEVERE; 500 MG/24 HR(S)-RABBIT-MILD; 162
MG-EYE-RABBIT-MILD; 500 MG/24 HR(S)-EYE-RABBIT-RABBI T-MILD. LD50:
>10000 MG/KG - SKIN-RABBIT (DOW); LD50: 2629 MG/KG - ORAL-RAT;
LD50: 4678 MG/KG - ORAL- MOUSE; LD50: 65 MG/KG - SUBCUTANEOUS -
MOUSE; LD50: 2100 MG/KG - ITRAPERITONEAL - DOG; LC50: 34200
MG/M3/8 HRS - INHALATION RAT; LC50: 5200 PPM/4 HR(S) - INHALATION -
MOUSE. MUTAGENICITY: MUTATION IN MICROORGANISMS-SALMONELLA
TYPIMURIUM 50 UL/PLATE. EPIDEMIOLOGY/TERATOGENICITY/NEUROTOXICTY:
NO DAT A AVAILABLE.
===================== Ecological Information =====================
Ecological:THIS MATERIAL IS HARMFUL TO AQUATIC LIFE. FISH TOXICITY:
8430 IG/L 96 HR(S) LC50 (MORTALITY) FLAGFISH (JORDANELLA FLORIDAE).
INVERTEBRATE TOXICITY: 7500 UG/L 49 HR(S) EC50 (IMMOBILIZATION)
WATER FLEA(DAPHNIA MAGNA). ALGAL TOXICITY: 50900 UG/L 96 HR(S)
EC50 (PHOTOSYNTHESIS) DIATOM (SKELETONEMA COSTATUM). FATE &
TRANSPORT: BIOCONCENTRATION: 49 UG/L 1-21 HR(S) BCF (RESIDUE)
BLUEGILL (LEPOMIS MACROC HIRUS) 3.43 UG/L.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE, OR LOCAL LAWS. STATE AND LOCAL REGULATIONS AND
RESTRICTIONS ARE COMPLEX AND MAY DIFFER FROM FRDERAL DISPOSAL
REGULATION. THE INFORMA TION OFFERED HERE IS FOR THE PRODUCT AS
SHIPPED.
=================== MSDS Transport Information ===================
Transport Information:DOT SHIPPING NAME: TETRACHLOROETHYLENE. DOT
HAZARD CLASS: 6.1. DOT ID NUMBER: UN1897. DOT PACKING GROUP: III.
OTHER LABEL(S) REQUIRED: KEEP AWAY FROM FOOD. IMDG HAZARD CLASS:
6.1. OTHER: MARINE POLLU TANT.
===================== Regulatory Information =====================
SARA Title III Information:SECTION 302: NO. SECTION 313: YES. SECTION
311/312: IMMEDIATE (ACUTE) HEALTH HAZARD, DELAYED (CHRONIC) HEALTH
HAZARD.
Federal Regulatory Information:CERCLA "REPORTABLE QUANTITY" (RQ) 100
LBS (TETRACHLOROETHYLENE). SPILLS/RELEASES RESULTING IN THE LOSS OF
THIS PRODUCT AT OR ABOVE ITS RQ REQUIRES NOTIFICATION TO THE
NATIONAL RESPONSE CENTER (800-424 -8802) AND TO YOUR LOCAL
EMERGENCY PLANNINGCOMMITTEE. TSCA INVENTORY STATUS: YES.
State Regulatory Information:WARNING: CONTAINS A CHEMICAL KNOWN TO THE
STATE OF CALIFORNIA TO CAUSE CANCER: TETRACHLOROETHYLENE.
MASSACHUSETTS SUBSTANCE LIST: TETRACHLOROETHYLENE. NEW JERSEY
WORKPLACE HAZARDOUS SUBSTANCE LIST: TE TRACHLOROETHYLENE.
PENNSYLVANIA HAZARDOUS SUBSTANCE SUBSTANCE LIST:
TETRACHLOROETHYLENE.
======================= Other Information =======================
======================================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:GLID-ZINC INORGANIC COATING 5530
CAGE:01PD6
CAGE:01PD6
============= Composition/Information on Ingredients =============
Ingred Name:ORGANOPHILIC CLAY
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:15 MG/M3
OSHA STEL:NE
ACGIH TLV:10 MG/M3
ACGIH STEL:NE
Ingred Name:KAOLIN
CAS:1332-58-7
RTECS #:GF1670500
Minumum % Wt:10.
Maxumum % Wt:20.
OSHA PEL:5 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:ETHANOL
CAS:64-17-5
RTECS #:KQ6300000
Minumum % Wt:30.
Maxumum % Wt:40.
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ingred Name:QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.1 MG/M3
Ingred Name:2-PROPANOL, 1-METHOXY-
CAS:107-98-2
RTECS #:UB7700000
Minumum % Wt:10.
Maxumum % Wt:20.
OSHA PEL:100 PPM
OSHA STEL:150 PPM
ACGIH TLV:100 PPM
ACGIH STEL:150 PPM
Ingred Name:SILICA
CAS:112926-00-8
RTECS #:VV7315000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:METHANOL
CAS:67-56-1
RTECS #:PC1400000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:200 PPM
OSHA STEL:250 PPM
ACGIH TLV:200 PPM
ACGIH STEL:250 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHANOL, 2-BUTOXY-
CAS:111-76-2
RTECS #:KJ8575000
Minumum % Wt:10.
Maxumum % Wt:20.
OSHA PEL:25 PPM
ACGIH TLV:25 PPM
Ingred Name:2-PROPANOL
CAS:67-63-0
RTECS #:NT8050000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:400 PPM
OSHA STEL:500 PPM
ACGIH TLV:400 PPM
ACGIH STEL:500 PPM
Ingred Name:SILICIC ACID, ETHYL ESTER
CAS:11099-06-2
Minumum % Wt:10.
Maxumum % Wt:20.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:REPORTS HAVE ASSOCIATED REPEATED &
PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS W/ PERMANENT BRAIN
& NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING & INHALING THE CONTENTS MAY BE HARMFUL OR FATAL.
Explanation of Carcinogenicity:PRODUCTS IN THESE SERIES CONTAIN
CRYSTALLINE SILICA, WHICH IS CONSIDERED A HAZARD BY INHALATION.
IARC HAS DETERMINED THAT THERE IS SUFFICIENT EVIDENCE FOR THE
CARCINOGENICITY OF CRYSTALLINE SILICA TO EXPERIMENTAL ANIMALS, AND
LIMITED EVIDENCE FOR THE CARCINOGENICITY OF CRYSTALLINE SILICA TO
HUMANS.
Effects of Overexposure:INHALATION:IRRITATION OF RESPIRATORY TRACT. MAY
LEAD TO FATIGUE, DROWSINESS, DIZZINESS AND/OR LIGHTHEADEDNESS,
HEADACHE, UNCOORDINATION, NAUSEA, VOMITING, COUGHING, APATHY,
CENTRAL NERVOUS SYSTEM DEPR ESSION, TIGHTNESS OF CHEST, ANESTHETIC
EFFECT OR NARCOSIS. SKIN:IRRITATION OF SKIN. DERMATITIS, DEFATTING,
SEVERE IRRITATION OR BURNS. SKIN CONTACT MAY RESULT IN DERMAL
ABSORPTION OF THIS PRODUCT WHIC H MAY CAUSE CENTRAL NERVOUS SYSTEM
DEPRESSION. EYE:BLURRED VISION, TEARING OF EYES, REDNESS OF EYES,
CORNEAL INJURY. INGESTION:MAY CAUSE LUNG INFLAMMATION & DAMAGE DUE
TO ASPIRATION OF MATERIAL INTO L UNGS.
Medical Cond Aggravated by Exposure:INGREDIENTS CONTAINED IN THESE
PRODUCTS HAVE BEEN REPORTED TO AGGRAVATE PREEXISTING EYE, SKIN,
RESPIRATORY, LUNG, BLOOD, KIDNEY AND LIVER DISORDERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE AND SUPPORT
CONTINUED BREATHING. HAVE TRAINED PERSON GIVE OXYGEN IF NECESSARY.
SKIN: WASH OFF QUICKLY WITH PLENTY OF WATER, THEN SOAP AND WATER;
REMOVE CON TAMINATED CLOTHING. WASH CONTAMINATED CLOTHING BEFORE
REUSE. EYE: FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF WATER,
ESPECIALLY UNDER LIDS, FOR AT LEAST 15 MINUTES. INGESTION: IF
SWALLOWED, OBTAIN MEDI CAL TREATMENT IMMEDIATELY. IN ALL CASES,
SEEK IMMEDIATE MEDICAL ATTENTION!
===================== Fire Fighting Measures =====================
Flash Point:=15.C, 59.F
Extinguishing Media:DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:WATER MAY BE USED TO COOL AND PROTECT EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT OR FIRE. VAPORS CAN FORM EXPLOSIVE
MIXTURES IN AIR AT ELEVATED TEMPERATURES. MAY DECOMPOSE UNDER FIRE
CONDITIONS EMITTING IRRITANT AND/OR T OXIC GASES.
================== Accidental Release Measures ==================
Spill Release Procedures:COMPLY WITH ALL APPLICABLE HEALTH AND
ENVIRONMENTAL REGULATIONS.ELIMINATE ALL SOURCES OF IGNITION.
VENTILATE AREA WITH EXPLOSION PROOF EQUIPMENT. SPILLS MAY BE
COLLECTED WITH NONCOMBUSTIBLE ABSORB ENT MATERIALS. USE
NON-SPARKING TOOLS. EVACUATE ALL UNNECESSARY PERSONNEL. TOXIC TO
FISH.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 80 F. KEEP AWAY FROM
HEAT, SPARKS, AND OPEN FLAME. DO NOT STORE IN ALUMINUM CONTAINERS.
Other Precautions:USE ONLY WITH ADEQUATE VENTILATION. DO NOT TAKE
INTERNALLY. KEEP OUT OF REACH OF CHILDREN. AVOID CONTACT WITH SKIN
AND EYES, AND BREATHING OF VAPORS. WASH HANDS THOROUGHLY AFTER
HANDLING, ESPECIALLY B EFORE EATING OR SMOKING. KEEP CONTAINERS
TIGHTLY CLOSED AND UPRIGHT WHEN NOT IN USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW
APPLICABLE STANDARDS. WHERE RESPIRATORY PROTECTION IS REQUIRED,
USE ONLY NIOSH/MSHA APPROVED RESPIRATORS IN ACCORDANCE WITH OSHA
STANDARD 29 CFR 1910.134.
Ventilation:PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT
BUILD-UP OF VAPORS. USE EXPLOSION-PROOF EQUIPMENT.USE
NON-SPARKING EQUIPMENT.
Other Protective Equipment:APRON, EYE WASH, SAFETY SHOWER
Supplemental Safety and Health
WT/GAL=8.9
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:147-343 F
Percent Volatiles by Volume:84.6
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, BASES, AMINES, MAGNESIUM.
Stability Condition to Avoid:ELEVATED TEMPERATURES, CONTACT WITH
OXIDIZING AGENT.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
=================== Toxicological Information===================
Toxicological Information:EXPOSURE TO MATERIALS IN THESE PRODUCTS HAVE
BEEN ASSOCIATED WITH POSSIBLE CARDIAC ABNORMALITIES, BLOOD
ABNORMALITIES, LIVER DAMAGE, KIDNEY DAMAGE. EXCESSIVE INHALATION
OF SOLVENT VAPORS UNDER UNCONT ROLLED CONDITIONS MAY LEAD TO
UNCONSCIOUSNESS, RESPIRATORY FAILURE, ASPHYXIATION, AND EVEN DEATH.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
=================== MSDS Transport Information ===================
Transport Information:DOT PROPER SHIPPING NAME: PAINT, UN 1263.
FLAMMABLE LIQUID.
===================== Regulatory Information =====================
SARA Title III Information:SARA SECTION 313: METHANOL, 2-BUTOXYETHANOL
Federal Regulatory Information:CERCLA: METHANOL
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DRY CLEANING SOLVENT
Preparer's Name:JIM COLE
CAGE:0A9L8
CAGE:0A9L8
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA, MEDIUM ALIPHATIC
CAS:64742-88-7
Fraction by Wt: 100%
Other REC Limits:NONE SPECIFIED
Ingred Name:BENZENE (SARA III)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: @ 0.05%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1PPM/5STEL;1910.1028
ACGIH TLV:10 PPM; A2; 9192
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:LIQUID IS IRRITATING TO EYES. VAPOR
MAY CAUSE EYE IRRITATION. LIQUID IS SLIGHTLY IRRITATING TO SKIN.
PROLONGED OR REPEATED CONTACT CAN RESULT IN DERMATITIS. VAPORS MAY
BE IRRITATING TO NOSE, THROAT & RESPIRATORY TRACT. INGESTION OF
PRODUCTMAY RESULT IN VOMITING. ASPIRATION OF VOMITUS INTO LUNGS MAY
CAUSE PNEUMONITIS.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:MAY CAUSE EYE, SKIN & RESPIRATORY TRACT
IRRITATION. MAY ALSO CAUSE HEADACHE, DIZZINESS AND NAUSEA.
ASPIRATION PNEUMONITIS MAY CAUSE COUGHING.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE SKIN MAY BE AT
INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH RUNNING WATER FOR 15 MINUTES WHILE HOLDING
EYELIDS OPEN. GET MEDICAL ATTENTION IMMEDIATELY. SKIN: WASH WITH
SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. GET MEDICAL ADVICE.
INHALATIO N: REMOVE TO FRESH AIR. GIVE MOUTH-TO-MOUTH RESUSCITATION
IF NOT BREATHING. GET MEDICAL ATTENTION. INGESTION: DO NOT INDUCE
VOMITING. RINSE MOUTH & DRINK LARGE AMOUNTS OF WATER. GET MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:147F,64C
Lower Limits:0.9
Upper Limits:6.1
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS. EXPLOSIVE AIR-VAPOR
MIXTURES MAY OCCUR.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP SMALL SPILLS WITH PAPER TOWEL. WEAR
ELIMINATE IGNITION SOURCES. DIKE TO RETAIN RUNOFF. VACUUM OR PUMP
FREE LIQUID. ABSORB RE SIDUE WITH INERT MATERIAL & PLACE IN SALVAGE
DRUM.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP
CONTAINERS CLOSED WHEN MATERIAL IS NOT IN USE. KEEP AWAY FROM
IGNITION SOURCES. AVOID PROLONGED OR REPEATED CONTACT.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED CHEMICAL CARTRIDGE
RESPIRATOR WITH FULL FACEPIECE AND ORGANIC VAPOR CARTRIDGES IN
COMBINATION WITH A HIGH-EFFICIENCY PARTICULATE FILTER.
Ventilation:LOCAL AND MECHANICAL(GENERAL) EXHAUST TO PROVIDE ADEQUATE
VENTILATION.
Other Protective Equipment:WEAR INDUSTRIAL WORK CLOTHING. USE RUBBER
APRON OR BOOTS IF NEEDED. HAVE EMERGENCY EYE WASH AND SAFETY SHOWER
AVAILABLE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING, DRINKING OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MIST. DO NOT INGEST. READ PRECAUTIONS ON
LABEL BEFORE USE.
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:369F,187C
Vapor Pres:<1 @ 20C
Vapor Density:5.2
Spec Gravity:0.79
Evaporation Rate & Reference:0.08 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID WITH PETROLEUM ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL OF WASTE AND HAZARDOUS MATERIAL SHALL
COMPLY WITH LOCAL, STATE AND FEDERAL ENVIRONMENTAL PROTECTION
AGENCY REGULATIONS. SEND WASTE MATERIAL TO AN APPROVED RECYCLING
FACILITY IF FEASIBLE. CITY , STATE AND FEDERAL REGULATIONS MUST
BEFOLLOWED.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:GOLDEN WEST HYDRAULIC OIL
CAGE:GO667
CAGE:GO667
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM HYDROCARBON *96-4*
CAS:64742-92-3
Fraction by Wt: 100%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION & DERMATITIS.
INHALATION: RESPIRATORY IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:DRYNESS, DEFATTING, IRRITATION, DIZZINESS,
HEADACHE.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED.
INGESTION: INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:410F
Extinguishing Media:CO2, WATER SPRAY/FOG, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:COOL EXPOSED CONTAINERS W/WATER SPRAY.
Unusual Fire/Explosion Hazard:PRESSURE INCREASE IN HEATED CONTAINERS.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP CONTAINERS CLOSED WHEN NOT IN USE. DON'T
STORE NEAR FLAME.
======================Handling and Storage ======================
Handling and Storage Precautions:WASH SKIN THOROUGHLY W/SOAP/WARM WATER
AFTER HANDLING.
Other Precautions:AVOID BREATHING FUMES. AVOID CONTACT W/SKIN.
============= Exposure Controls/Personal Protection =============
Ventilation:LOCAL EXHAUST
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:600F
Vapor Pres:<1
Vapor Density:>1
Spec Gravity:0.85
Evaporation Rate & Reference:(BU AC = 1): <1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT TO DARK AMBER COLOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
STRONG OXIDANTS
Stability Condition to Avoid:EXTREME HEAT
Hazardous Decomposition Products:PARTIAL BURNING PRODUCES FUMES, SMOKE
& CO.
Conditions to Avoid Polymerization:ONLY IF MIXED W/METALS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LUGOL'S IODINE, 21-671
CAGE:IO995
CAGE:3936X
CAGE:IO995
============= Composition/Information on Ingredients =============
Ingred Name:IODINE
CAS:7553-56-2
RTECS #:NN1575000
Fraction by Wt: 5.0%
OSHA PEL:C 0.1 PPM
ACGIH TLV:C 0.1 PPM; 9495
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DANGER! POISON, MAY BE HARMFUL OR
FATAL IF SWALLOWED. MAY CAUSE IRRITATION TO SKIN, EYES AND
RESPIRATORY TRACT. AVOID BREATHING VAPOR AND EYE OR SKIN CONTACT.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING EYE, SKIN
OR RESPIRATORY DISORDERS MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF
THIS SUBSTANCE.
======================= First Aid Measures =======================
First Aid:INHALATION: NOT APPLICABLE UNDER NORMAL CONDITIONS OF USE.
SEEK MEDICAL ASSISTANCE IF NECESSARY. EYE: WASH IMMEDIATELY WITH
COPIOUS AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. CALL PHYSICIAN.
SKIN: WASHIMMEDIATELY WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST
15 MINUTES. REMOVE CONTAMINATED CLOTHING. CALL PHYSICIAN.
INGESTION: CALL PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE EXTINGUISHING MEDIA APPLICABLE TO SURROUNDING
FIRE CONDITIONS.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:EMITS HIGHLY TOXIC FUMES OF IODINE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROT CLOTHING & EQUIP SPECIFIED. WEAR
SCBA/RESPIRATOR W/APPRVD NIOSH/MSHA CARTRIDGES, IF NEC. CONTAIN
SPILL & FLUSH AREA WITH 1-5% SODIUM BISULFITE & H*2O SOLUTION.
ABSORB W/INERT MATERIAL, SCOOP UP & PLACE IN APPRVD HAZ WASTE
CNTNR.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NOT REQUIRED UNDER NORMAL CONDITIONS OF USE.
Ventilation:MECHANICAL EXHAUST, FUME HOOD.
Other Protective Equipment:PROTECTIVE APRON OR GOWN AS REQUIRED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SOLUBILITY IN WATER: INSOLUBLE (SOLUBLE IN AQUEOUS IODINE SOLN)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:185F,85C
Melt/Freeze Pt:M.P/F.P Text:114F,45C
Vapor Pres:1 @ 107F
Spec Gravity:4.93
Evaporation Rate & Reference:>1 (ETHER=1)
Solubility in Water:(SUPDAT)
Appearance and Odor:VIOLET-BLACK CRYSTALS, METALLIC LUSTER.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG REDUCING AGENTS, STRONG ACIDS; MAY REACT WITH METALS.
Stability Condition to Avoid:EXTREME HEAT.
Hazardous Decomposition Products:IODINE FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:ENSURE COMPLIANCE WITH ALL LOCAL, STATE, AND
FEDERAL REGULATIONS OR CONTACT AN APPROVED AND LICENSED DISPOSAL
AGENCY.
| 1 | eyes_protection_mandatory |
Product ID:832 0228 FLEXICOLOR STABILIZER & REPLENISHE
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:DIETHANOLAMINE (SARA 313) (CERCLA)
CAS:111-42-2
RTECS #:KL2975000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3 PPM
ACGIH TLV:0.46 PPM; 9596
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:POLYVINYLPYRROLIDONE
CAS:9003-39-8
RTECS #:TR8370000
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:PROPYLENE GLYCOL
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SUBSTITUTED THIAZOLIN-3-ONE/1,2-BENZISOTHIAZOL-3(2H)-ONE
CAS:2634-33-5
RTECS #:DE4620000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 65 - 70%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
Ingred Name:HEXAMETHYLENETETRAMINE/HEXAMINE
CAS:100-97-0
RTECS #:MN4725000
Fraction by Wt: 20 - 25%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY &
GI TRACTS. ACUTE- CAUSES EYE & SKIN IRRITATION, ALLERGIC REACTION.
UNDER ACIDIC CONDITIONS, FORMS FORMALDEHYDE WHICH CAUSES
RESPIRATORY SENSITIZATION. HARMFUL IF INHALED/INGESTED/ABSORBED
THROUGH SKIN. CHRONIC- BASED ON ANIMAL DATA MAY CAUSE ADVERSE
EFFECTS ON LIVER, KIDNEY, CNS.
Explanation of Carcinogenicity:IF FORMALDEHYDE IS FORMED, IT IS A
POTENTIAL CARCINOGEN.
Effects of Overexposure:IRRITATION, ALLERGIC SKIN REACTION, NAUSEA,
VOMITING, RESPIRATORY SENSITIZATION, TEARING
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION MAY BE
MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:CALL PHYSICIAN IF SYMPTOMS DEVELOP. EYE:IMMEDIATELY FLUSH
WITH WATER FOR 15 MINUTES. HOLD EYELIDS OPEN. CALL PHYSICIAN.
SKIN:FLUSH WITH PLENTY OF WATER. INHALED:MOVE TO FRESH AIR. PROVIDE
CPR/OXYGEN I F NEEDED. ORAL:ONLY INDUCE VOMITING AT INSTRUCTION OF
PHYSICIAN. CALL A PHYSICIAN/POISON CONTROL CENTER IMMEDIATELY.
NEVER GIVE FLUID OR INDUCE VOMITING IF PATIENT IS UNCONSCIOUS OR
HAS CONVULSIONS.
===================== Fire Fighting Measures =====================
Flash Point:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH SPILL TO SEWER WITH LARGE AMOUNT OF
WATER IF REGULATIONS ALLOW. OTHERWISE, ABSORB SPILL WITH
VERMICULITE. PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN SURFACE
THOROUGHLY TO REMOVE RESIDUAL CON TAMINATION.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM INCOMPATIBLES. KEEP
CONTAINER CLOSED. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:AVOID CONTACT WITH EYES, SKIN AND CLOTHING. USE WITH
ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING. CONTACT WITH
ACID FORMS HARMFUL GAS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF FORMALDEHYDE IS EMITTED ABOVE TLV, WEAR
NIOSH-APPROVED FULL FACEPIECE RESPIRATORY PROTECTION AGAINST
FORMALDEHYDE. IF RESPIRATORS ARE USED, A PROGRAM SHOULD BE
INSTITUTED TO ASSURE COMPLIANCE WITH OSHA STANDARD 29CFR
1910.134/1048.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES/HR)
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:EYE BATH, SAFETY SHOWER, WASHING FACILITIES
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
DIFFERENT FORMULA. FOR WORKING SOLUTION, SEE PNI X. ECOLOGICAL
INFORMATION: A LOW BIOCHEMICAL OXYGEN DEMAND, A LOW POTENTIAL TO
AFFECT SOME AQUATIC ORGANISMS. AFTER DILUTION WITH WATER, FOLLOWED
BY SE CONDARY WASTE TREATMENT, THIS MATERIAL IS NOT EXPECTED TO
CAUSE ADVERSE ENVIRNMENTAL EFFECTS.
================= Stability and Reactivity Data =================
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE OR LOCAL LAWS. FLUSH TO SEWER WITH LARGE AMOUNT
OF WATER. SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUE, FOLLOW
LABEL WARNINGS EVEN AFTER CONTAINER IS EMPTIED.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: CLEAN-GEAR 747, CG747
Cage: 3J051
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 3J051
=======================================================
Item Description Information
=======================================================
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES: REDNESS, SEVERE EYE DAMAGE. SKIN: REDNESS, POSSIBLE
SKIN IRRITATION. INGEST: PROBABLE MUCOSAL DAMAGE, POSSIBLE RESPIRATORY
DEPRESSION, POSSIBLE CONVULSIONS. ANIMAL STUDIES HAVE CLEARLY DEMONSTRA TED
DOSE-RELATED ADVERSE EFFECTS ON THECNS, THE HEMATOPOIETIC TISSUE, THE BLOOD,
THE KIDNEYS, & THE (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ:LIVER ASSOCIATED WITH THE
ADMINISTRATION OF ETHYLENE GLYCOL MONOBUTYL ETHER (EGBE) AND ETHYLENE GLYCOL
MONOBUTYL ETHER ACETATE (EGBEA). (EXTRACTED FROM DHHS (NIOSH) PUBLICATION NO.
90-118) (F P N). SYMPTOMS OF OVEREXP: NONE KNOWN.
Medical Cond Aggravated By Exposure: NOT KNOWN.
First Aid: EYES:FLUSH IMMED WITH WATER FOR AT LEAST 15 MIN. CALL PHYS.
SKIN:IMMED STOP USING PROD & WASH AREA WITH WATER FOR 15 MIN-IF
IRRITATION PERSISTS CALL PHYS. INGEST:DRINK MILK, EGG WHITES, GELATIN SOLUTI
ON OR IF THESE ARE NOT AVAILABLE, DRINKLG QTY OF WATER. CALL PHYS.
INHAL:REMOVE TO FRESH AIR. SUPPORT BRTHG. (GIVE O*2/ARTF RESP) (FP N).
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS (FP N).
Handling And Storage Precautions: DO NOT CONTAMINATE FOOD OR WATER BY STORAGE
OR DISPOSAL. AVOID PROLONGED EXPOSURE SKIN. DO NOT GET IN EYES, OR CLOTHING.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: NONE TO BOILING
Extinguishing Media: CO*2, DRY CHEMICAL, FOAM, WATER SPRAY.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE KNOWN.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT NEEDED UNDER NORMAL CONDITIONS OF USE. WEAR
NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN (FP N).
Ventilation: NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment: NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: PH: 12.5-0.5.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: T6
B.P. Text: 212F,100C
Spec Gravity: 1.015+0.005
PH: SUPDAT
Evaporation Rate & Reference: ABOUT THE SAME (VS. H*2O)
Solubility in Water: COMPLETE
Appearance and Odor: YELLOWISH LIQUID, PLEASANT ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: STRONG OXIDIZERS ANIONIC COMPOUNDS.
Hazardous Decomposition Products: CO & OTHER UNIDENTIFIED ORGANIC GASES MAY
OCCUR DURING INCOMPLETE COMBUSTION.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 30406
Product ID: CLEAN-GEAR 747, CG747
Review Date: 03/04/1993
Multiple KIT Number: 0
Review IND: Y
Additional Data: NOT REGULATED FOR TRANSPORTATION
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: CLEAN-GEAR 747, CG747
Cage: 3J051
Company Name: GEORGIA STEEL & CHEMICAL CO INC
Street: 10810 GUILFORD RD
Zipcode: 20701
Label Required IND: Y
Date Of Label Review: 02/04/1992
Status Code: C
Label Date: 02/04/1992
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: DO NOT CONTAM FOOD/H*2O BY STORAGE OR DISPOSAL. AVOID
PROLONGED SKIN EXPOS. DO NOT GET IN EYES, OR CLTHG. ACUTE: EYES:REDNESS, SEV
EYE DAM. SKIN:REDNESS, POSSIBLE SKIN IRRIT. INGEST:PROBABLE MUCOSAL D AMAGE,
POSSIBLE RESPIRATORY DEPRESSION,POSSIBLE CONVULSIONS. CHRONIC: ANIMAL STUDIES
HAVE CLEARLY DEMONSTRATED DOSE-RELATED ADVERSE EFFECTS ON THE CNS, BLOOD
FORMING TISSUE, BLOOD, KIDNEYS & LIVER ASS OCIATED WITH THE
ADMINISTRATION OF ETHYLENE GLYCOL MONOBUTYL ETHER (EGBE) AND ETHYLENE GLYCOL
MONOBUTYL ETHER ACETATE (EGBEA).
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ENAMEL, ALKYD, GLOSS, LO VOC CT, WHITE 17875, ID 774720
Preparer's Name:W A ELLISON
CAGE:61196
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:N-BUTYL ACETATE (SOLVENT) (VAPOR PRESSURE 10 MM HG @ 20C)
(LFL 1.7; UFL 7.6)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:150 PPM;STEL 200 PPM
ACGIH TLV:150 PPM;STEL 200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SOLVENT NAPHTHA, LIGHT AROMATIC (SOLVENT)
CAS:64742-95-6
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:1,2,4-TRIMETHYLBENZENE (SOLVENT) (SARA III)
CAS:95-63-6
RTECS #:DC3325000
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:XYLENE (SOLVENT) (SARA III) (VAPOR PRESSURE 5 MM HG @ 20C)
(LFL 1.0; UFL 7.0)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM;STEL 150 PPM
ACGIH TLV:100 PPM;STEL 150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TITANIUM DIOXIDE (PIGMENT)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 25%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:SILICA, AMORPHOUS HYDRATED (PIGMENT)
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:TRIMETHYL BENZENE
CAS:25551-13-7
RTECS #:DC3220000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:25 PPM; 125 MG/M3
ACGIH TLV:25 PPM; 125 MG/M3
Ingred Name:VOC: 3.12 LB/GAL LESS WATER & NEGLIGIBLY PHOTOCHEMICALLY
REACTIVE MATERIALS; 374 G/L LESS WATER; CALCULATED
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:INGESTION: GASTROINTESTINAL
IRRITATION, NAUSEA, VOMITING. ASPIRATION INTO LUNG MAY CAUSE CHEM
PNEUMONITIS (CAN BE FATAL). INHALATION: NOSE OR THROAT IRRITATION.
ACUTE CENTRAL NERVOUS SYSTEM DEPRESSION (HEADACHES, DIZZINESS,
NAUSEA, CONFUSION). EYE: SEVERE IRRITATION & CORNEAL DAMAGE. SKIN:
DEFATTING & SKIN IRRITATION.
Effects of Overexposure:CHRONIC: LIVER, KIDNEY AND BLOOD INJURY.
PROLONGED & REPEATED OVEREXPOSURE ASSOCIATED WITH PERMANENT BRAIN &
NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING & INHALING PRODUCT MAY BE HARMFUL OR FATAL.
======================= First Aid Measures =======================
First Aid:INGEST: DONT INDUCE VOMITING. CALL POISON CTR/EMERG ROOM/DR
IMMED. INHAL:REMOVE TO FRESH AIR IMMED. IF BREATHING STOPPED, GIVE
ARTIF RESPRTN. KEEP WARM & QUIET. GET MED AID IMMED. EYE: FLUSH
W/WATER 1 5 MIN, LIFTING EYELIDS. GET MED AID. SKIN: REMOVE CONTAM
CLOTHES. WASH AFFECTED AREA W/SOAP & WATER. GET MED AID IF IRRIT
PERSISTS. NOTE TO DR:DIRECT TREATMENT AT CLINICAL CONDITION &
SYMPTOM CONTROL.
===================== Fire Fighting Measures =====================
Flash Point:72.0F,22.2C
Autoignition Temp:Autoignition Temp Text:572 F
Lower Limits:1.0
Upper Limits:7.6
Extinguishing Media:NFPA CLASS B EXTINGUISHERS (CO2, DRY CHEMICAL,
ALCOHOL FOAM) FOR FLAMMABLE LIQ. POLYMER FOAM PREFERRED FOR LARGE
FIRES.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE, USE TO COOL EXPOSED
CONTAINERS (FOG NOZZLES PREFERRED) TO PREVENT PRESSURE BUILDUP,
AUTOIGNITION OR EXPLOSION WHEN EXPOSED TO HEAT.
Unusual Fire/Explosion Hazard:DURING EMERGENCY CONDITIONS, OVEREXPOSURE
TO DECOMPOSITION PRODUCTS MAY BE HEALTH HAZARD. SYMPTOMS MAY NOT BE
IMMEDIATELY APPARENT. GET MEDICAL AID. FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR RSPRTR,EYE,HAND,BODY PROTECTN. KEEP
SPECTATORS AWAY. ELIMINATE IGNIT SOURCES. DIKE & CONTAIN W/INERT
MAT'L (SAND/EARTH/ETC). TRANSFER LIQ/USED ABSORBENT TO COVERED
METAL CONTAINER. USE NON-SPARKI NG TOOL. PREVENT SEWER, GROUNDWATER
CONTAMINATION.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 115 F. STORE LARGE
QUANTITIES IN COMPLIANCE WITH OSHA 29 CFR 1910.106. DO NOT TAKE
INTERNALLY. DO NOT BREATHE SANDING DUST.
Other Precautions:CLOSE CONTAINER AFTER EACH USE. DO NOT WASH & REUSE
EMPTY CONTAINER FOR ANY PURPOSE. GROUND & BOND CONTAINERS TO
RECEIVING CONTAINER. DO NOT WELD, BRAZE, OR CUT ON EMPTY CONTAINER.
NEVER USE PRESSURETO EMPTY. DRUM IS NOT A PRESSURE VESSEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTD,MAY NOT REQ RSPRTR.IN RESTRICTD
VENT,NIOSH CHEM CARTRIDGE RSPRTR MAY BE REQ'D.SPRAYNG,MECHAN
PREFILTER MAY ALSO BE REQ'D.CONFIND AREAS,USE AIR SUPPLD RSPRTR.SEE
OSHA 29CFR1910.134"RESP PROTEC T"&"RESP PROTECT-MANUAL &
GUIDELINE"AIHA
Ventilation:LOCAL EXHAUST VENT TO KEEP BELOW TLV. REMOVE DECOMPOSITION
PRODUCT. SEE "INDUST VENT-MANUAL RECOMMENDED PRACTICES" ACGIH
Other Protective Equipment:EYEWASH FACILITY, SAFETY SHOWER.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:165 TO 355F
Melt/Freeze Pt:M.P/F.P Text:-50F,-46C
Decomp Temp:Decomp Text:1832F,1000C
Vapor Pres:10 @ 68F
Vapor Density:> AIR
Spec Gravity:1.3
pH:4-7
Viscosity:67 - 77 KU
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Solubility in Water:SLIGHT IN WATER
Appearance and Odor:LIQUID, SOLVENT ODOR
Percent Volatiles by Volume:42
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS. OXIDIZING MATERIALS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT (>115F) AND SOURCES
OF IGNITION.
Hazardous Decomposition Products:BURNING, INCLUDING WHEN HEATED BY
WELDING OR CUTTING, WILL PRODUCE SMOKE, CARBON MONOXIDE & CARBON
DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE, &
LOCAL LAWS OR REGULATIONS. THIS PRODUCT, IF DISCARDED DIRECTLY,
WOULD BE CLASSIFIED A HAZARDOUS WASTE BASED ON ITS IGNITABILITY
CHARACTERISTIC (FLASH POINT 140F OR LESS). PROPER RCRA
CLASSIFICATION: D001.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:3254 GRAY PRIMEEZ
CAGE:MART2
CAGE:MART2
============= Composition/Information on Ingredients =============
Ingred Name:VOL ORGANIC CMPD: TOTAL VOLATILE ORGANIC COMPOUNDS & LESS
WATER & EXEMPT SOLVENTS 4.45
RTECS #:9999999VO
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 30%
Other REC Limits:375 MG/CUM
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 4%
Other REC Limits:400 PPM
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
Ingred Name:HEXONE, METHYL ISOBUTYL KETONE (MIBK), 4-METHYL-2-PENTANONE
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 6%
Other REC Limits:50 PPM
OSHA PEL:100 PPM/75 STEL
ACGIH TLV:50 PPM/75 STEL; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:BUTYL ACETATE (N-BUTYL ACETATE)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 3%
Other REC Limits:150 PPM
OSHA PEL:700 MG/CUM
ACGIH TLV:713 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 27%
OSHA PEL:20 MPPCF
ACGIH TLV:2 MG/CUM (RESP DUST)
Ingred Name:TITANIUM DIOXIDE, TIO2
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 7%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:WEIGHT PER GALLON IN POUNDS: 10.10
RTECS #:9999999WG
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION/ALLERGIC REACTION.
INHALATION: IRRITATION/ALLERGIC REACTION TO RESPIRATORY
SYSTEM/FATAL. PROLONGED OVEREXPOSURE TO SOLVENTS CAUSES ADVERSE
EFFECTS TO LIVER/URINARY/BLOOD FORMING/REPRO DUCTIVE/CARDIOVASCULAR
SYSTEMS/PERMANENT BRAIN/NERVOUS SYSTEM DAMAGE. ALCOHOL & ACETATE
ABSORPTION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: HEADACHE/DIZZINESS/NAUSEA/LOSS OF
COORDINATION/IRRITATION OF RESPIRATORY SYSTEM, UNCONSCIOUSNESS,
DEATH. SKIN/EYES: REDNESS/ITCHING/BURNING SENSATION/IRRITATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SKIN: WASH AFFECTED AREA
THOROUGHLY W/SOAP & WATER. EYES: FLUSH W/LARGE AMOUNTS OF WATER FOR
15 MINS. INGESTION: OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:40F
Lower Limits:0.7%
Upper Limits:12.7%
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT INCLUDING SCBA.
WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE
PREFERRABLE.
Unusual Fire/Explosion Hazard:WATER MAY BE USED TO COOL CLOSED
CONTAINERS TO PREVENT PRESSURE BUILD-UP, POSSIBLE AUTOIGNITION, OR
EXPLOSION WHEN EXPOSED TO EXTREME HEAT. FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES. VENTILATE AREA/REMOVE
W/INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T SMOKE IN AREA. AVOID CONTACT
W/SKIN/EYES. USE APPROVED BONDING/GROUNDING PROCEDURE. KEEP FROM
CHILDREN. FLAMMABLE.
Other Precautions:KEEP CONTAINER TIGHTLY CLOSED WHEN NOT IN USE.
TRANSFER ONLY TO APPROVED CONTAINERS W/COMPLETE/APPROPRIATE
LABELING. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING/INHALING
CONTENTS CAN BE HARMFUL/F ATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR PROPERLY FITTED ORGANIC VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA FOR PROTECTION AGAINST MATERIALS.
WHEN SANDING/WIREBRUSHING/ABRADING/BURNING/WELDING DRIED FILM, WEAR
PARTICULATE RESPI RATOR APPROVED BY NIOSH/MSHA.
Ventilation:LOCAL EXHAUST: PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF
EXPOSURE TO MATERIALS IS MAINTAINED BELOW APPLICABLE LIMITS.
Work Hygienic Practices:WASH HANDS AFTER USING. REMOVE/LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
THIS COATING MAY CONTAIN MATERIALS CLASSIFIED AS NUISANCE PARTICULATES
WHICH MAY BE PRESENT AT HAZARDOUS LEVELS ONLY DURING
SANDING/ABRADING OF THE DRIED FILM. THIS MATERIAL IS
PHOTOCHEMICALLY REACTIV E. APPLICATIONS TO HOT SURFACES REQUIRES
SPECIAL PRECAUTIONS. AVOID BREATHING VAPORS/MIST. AVOID HEAT
SOURCES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:132-302F
Vapor Density:>1
Spec Gravity:0.82-1.2
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:63-100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT/ELECTRICAL EQUIPMENT/SPARKS/OPEN
FLAMES/HOT SURFACES/PILOT LIGHTS/HEATERS/STOVES/OTHER SOURCES OF
IGNITION
Hazardous Decomposition Products:CO2, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:PRODUCT WASTE IS RCRA HAZARD. TEST FOR
IGNITABILITY TO DETERMINE APPLICABLE EPA HAZARDOUS WASTE NUMBER.
INCINERATE IN APPROVED FACILITY ACCORDING TO REGULATIONS. DON'T
INCINERATE CLOSED CONTAINERS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: RICH LUX PATIO AND DECK ENAMEL, 077412
Cage: 85519
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 85519
Box: 600
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHALATION: IRRITATION OF RESPIRATORY TRACT. PROLONGED
INHALATION MAY LEAD TO MUCOUS MEMBRANE IRRITATION DROWSINESS, AND/OR
LIGHT-HEADEDNESS, HEADACHE, NAUSEA. SKIN: IRRITATION OF SKIN. PROLONGED OR R
EPEATED CONTACT CAN CAUSE DERMATITIS. EYE: IRRITATION OF EYES. PROLONGED OR
REPEATED CONTACT CAN (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: CREATE BLURRED VISION, CORNEAL
INJURY. INGESTION: AMOUNTS INGESTED INCIDENTAL TO CONSUMER AND INDUSTRIAL
HANDLING ARE NOT LIKELY TO CAUSE INJURY; HOWEVER, INGESTION OF LARGER AMOUNTS
COULD C AUSE SERIOUS INJURY.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL: REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
HAVE TRAINED PERSON GIVE OXYGEN IF NEC. GET EMER MED ATTN. SKIN: WASH OFF
QUICKLY W/PLENTY OF H*2O, THEN SOAP & H*2O; REMOVE CONTAMD CLTH G. WASH
CONTAMD CLTHG BEFORE REUSE. EYE: FLUSH IMMED W/LRG AMTS OF H*2O, ESP UNDER
LIDS, FOR AT LEAST 15 MIN. OBTAIN EMER MEDICAL TREATMENT. INGEST: IF
SWALLOWED, OBTAIN MEDICAL TREATMENT IMMEDIATELY.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: COLLECT IN CONTAINER FOR DISPOSAL, ACCORDING TO
HEALTH AND ENVIRONMENTAL REGULATIONS. CLEAN UP WITH WATER BEFORE ALLOWING TO
DRY.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
Handling And Storage Precautions: STORE BELOW 100 DEGREE F. KEEP FROM FREEZING.
Other Precautions: DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NON-FLAMMABLE
Lower Limits: SEE INGRED
Extinguishing Media: DRY CHEMICAL OR FOAM.
Fire Fighting Procedures: NON-FLAMMABLE. WATER MAY BE USED TO COOL AND PROTECT
EXPOSED CONTAINERS. USE NIOSH APPROVED SCBA & FULL PROTECTIVE EQUIPMENT
(FP N).
Unusual Fire/Explosion Hazard: CLOSED CONTAINERS MAY BURST IF EXPOSED TO
EXTREME HEAT OR FIRE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW APPLICABLE
STANDARDS. WHERE RESPIRATORY PROTECTION IS REQUIRED, USE ONLY NIOSH APPROVED
RESPIRATORS IN ACCORDANCE WITH OSHA STANDARD 29 CFR 1910.134.
Ventilation: MAINTAIN ADEQUATE VENTILATION TO ENSURE AIR ENTRY DURING
APPLICATION AND DRYING TO PREVENT BUILD-UP OF VAPORS.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N). SKIN CREAM (IF NEEDED).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >212F,>100C
Vapor Pres: SEE INGRED
Spec Gravity: 1.13-1.37(FP N)
Evaporation Rate & Reference: SLOWER THAN ETHYL ETHER
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume: 64-68
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: ELEVATED TEMPERATURES. CONTACT WITH OXIDIZING
AGENTS.
Materials To Avoid: OXIDIZERS, ACIDS, BASES, AMINES.
Hazardous Decomposition Products: IF INVOLVED IN FIRE (FROM OTHER SOURCES)
COULD CONCEIVABLY RESULT IN RELEASE OF CARBON DIOXIDE AND CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: RICH LUX PATIO AND DECK ENAMEL, 077412
Cage: 85519
Company Name: M A BRUDER & SONS INC
Street: 600 REED RD
PO Box: 600
Zipcode: 19008
Label Required IND: Y
Date Of Label Review: 03/10/1997
Status Code: C
Label Date: 03/10/1997
Origination Code: G
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: INHALATION: IRRITATION OF RESPIRATORY TRACT.
PROLONGED INHALATION MAY LEAD TO MUCOUS MEMBRANE IRRITATION DROWSINESS,
AND/OR LIGHT-HEADEDNESS, HEADACHE, NAUSEA. SKIN: IRRITATION OF SKIN. PROLONG
ED OR REPEATED CONTACT CAN CAUSE DERMATITIS. EYE: IRRITATION OF EYES.
PROLONGED OR REPEATED CONTACT CAN CREATE BLURRED VISION, CORNEAL INJURY.
INGESTION: AMOUNTS INGESTED INCIDENTAL TO CONSUMER AND IN DUSTRIAL HANDLING
ARE NOT LIKELY TO CAUSE INJURY; HOWEVER, INGESTION OF LARGER AMOUNTS COULD
CAUSE SERIOUS INJURY. CHRONIC: NONE SPECIFIED BY MANUFACTURER.
=======================================================
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: 504 RESPIRATOR CLEANING WIPE
Cage: 1BY21
=======================================================
Contractor Summary
=======================================================
Cage: 76381
Cage: 1BY21
=======================================================
Ingredients
=======================================================
Cas: 7732-18-5
RTECS #: ZC0110000
% Wt: 60-70
------------------------------
% Wt: 30-40
-----------------------------
Cas: 8001-54-5
RTECS #: BO3150000
CHLORIDES)
% Wt: <1
------------------------------
Cas: 9036-19-5
RTECS #: MD0907600
(SURFACTANT)
% Wt: <0.5
------------------------------
% Wt: <0.5
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:EYE: DIRECT CONTACT OF LIQUID W/EYES MAY CAUSE MILD
IRRITATION. SKIN: NO ADVERSE HEALTH EFFECTS FROM SKIN CONTACT ARE EXPECTED.
INHAL: NO ADVERSE HEALTH EFFECTS FROM INHAL ARE EXPECTED. INGEST: NO ADVERSE
HLTH EFTS FROM INGEST ARE EXPECTED. AN ORAL TOXICITY STUDY CONDUCTED ON LIQ
PORTION (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ: OF THIS PRODUCT INDICATED THE
LIQUID WAS PRACTICALLY NON-TOXIC ORALLY.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYE: IMMED FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. CALL
A PHYSICIAN. SKIN: WASH AFFECTED AREA WITH SOAP AND WATER. IF IRRITATION
PERSISTS, CALL A PHYSICIAN. INHAL: REMOVE TO FRESH AIR. IF SYMPTOMS
CONTINUE, CALL A PHYSICIAN. INGEST: DO NOT INDUCE VOMIT. IF CONSCIOUS GIVE
1-2 GLASSES OF WATER. IMMEDIATELY CALL A PHYSICIAN.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: OBSERVE PREC FROM OTHER SECTIONS. VENTILATE, CONTAIN
SPILL, COLLECT SPILLED MATERIAL AND PLACE IN CLOSED CONTAINER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: MIX W/FLAMMABLE MATERIAL & INCINERATE IN AN
INDUSTRIAL OR COMMERICAL INCINERATOR. SINCE REGULATIONS VARY, CONSULT APPLIC
FEDERAL, STATE & LOCAL REGULATIONS OR AUTHORITIES BEFORE DISPOSAL.
Handling And Storage Precautions: AVOID EYE CONT. ALLOW CLEANED EQUIP TO THORO
DRY PRIOR TO USE. DO NOT USE IF RASH/OTHER SKIN IRRIT IS PRESENT. KEEP OUT OF
REACH OF CHILDREN.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, WATER.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP M).
Unusual Fire/Explosion Hazard: NONE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN (FP N).
Ventilation: NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment: NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: BP: CA 212F, 100C EXCLUDING TOWELLETTE. SPEC
GRAV: CA 1.000 WATER=1, EXCLUDING TOWELETTE. PH: 5.75-6.75 EXCLUDING
TOWELETTE. % VOLAT: 90 EXCLUDING TOWELETTE.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
B.P. Text: SUPP DATA
Spec Gravity: SUPP DATA
PH: SUPDAT
Solubility in Water: COMPLETE
Appearance and Odor: TOWELLETTE, COLOR, WITH LEMON ODOR.
Percent Volatiles by Volume: SUPDAT
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: SOAPS/ANIONIC SURFACTANTS.
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 40597
Product ID: 504 RESPIRATOR CLEANING WIPE
Review Date: 04/28/1993
Multiple KIT Number: 0
Review IND: Y
Additional Data: NOT REGULATED FOR TRANSPORTATION
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: 504 RESPIRATOR CLEANING WIPE
Cage: 1BY21
Company Name: MINNESOTA MINING AND MFG CO ENGINEERING DOCUMENT SYSTEMS DIV
Street: 3M CTR
Zipcode: 55144-1000
Label Required IND: Y
Date Of Label Review: 11/03/1992
Status Code: C
Label Date: 11/03/1992
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: DIRECT CONTACT OF LIQUID WITH EYES MAY CAUSE
MILD IRRITATION. CHRONIC: NONE LISTED BY MANUFACTURER.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:22-209
CAGE:EO032
CAGE:EO032
CAGE:72653
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 100%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE GIVEN
Effects of Overexposure:DERMITIS,SEVERE EYE IRRITATION,BLURRED
VISION,NASAL AND RESPIRATORY IRRITATION, DIZZINESS,
HEADACHE,FATIGUE,NAUSEA,UNCONSCIENOUS,GASTROINTESTINAL
IRRITATION,DIARRHEA. ASPIRATION INTO LUNGS CAN CAUSEE CHEMICAL
PNEUMONITIS AND CAN BE FATAL.PERSONS WITH CENTRAL NERVOUS SYSTEM
OER LIVER DISEASEE SHOULD AVOIUD EXPOSURE.
Medical Cond Aggravated by Exposure:NONE GIVEN
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH WATER FOR AT LEAST 15MINUTES. SKIN:WASHWITH
SOAP AND WATER. INHALATION:FRESH AIR, OXYGEN, ARTIFICIAL
RESPIRATION IF NECESSARY. INGESTION: CONSULT A PHYSCIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:39.9F,4.4C
Lower Limits:1.4
Upper Limits:6.7
Extinguishing Media:CO2,CHEM FOAM,
Fire Fighting Procedures:SCBA RECOMMENDED - COMBUSTION PRODUCTS MAY BE
TOXIC
Unusual Fire/Explosion Hazard:HEAVY VAPORS MAY TRAVEL LONG DISTANCES TO
AN IGNITION SOURCES.,
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION-ABSORB WITH AN
INERT MATERIAL-STORE IN METAL CONTAINER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID HIGH TEMPERATURES AND IGINITION
SOURCES, STORE IN A COOL, WELL- VENTILATED AREA.
Other Precautions:AVOID EXPOSURE ABOVE TLV LIMITS
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SCBA OR CHEMICAL CARTRIDGE RESPIRATOR
Ventilation:YES, MECHANICAL IF REQUIRED TO MEET TVL
Other Protective Equipment:APRON IF NECESSARY
Work Hygienic Practices:PRUDENT
Supplemental Safety and Health
NONE GIVEN
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:231F,111C
Vapor Pres:36.7MMHG
Vapor Density:3.14
Spec Gravity:0.866
Evaporation Rate & Reference:1
Solubility in Water:NO
Appearance and Odor:CLEAR COLORLESS-BENZINE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:HEAT AND IGNITION SOURCES
Hazardous Decomposition Products:C0, C02
==================== Disposal Considerations ====================
Waste Disposal Methods:LISCENSED INCINERATOR OR PER GOVERNMENT
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:2-BUTANONE, 99+%, 11026-4
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTANONE;(METHYL ETHYL KETONE) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
OSHA PEL:200 PPM;300 STEL
ACGIH TLV:200 PPM;300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL RAT)2737 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:MAY BE HARMFUL BY INHALATION,
INGESTION OR SKIN ABSORPTION. CAUSES SEVERE EYE IRRITATION. CAUSES
SKIN IRRITATION. CAN CAUSE CNS DEPRESSION. MATERIAL IS IRRITATING
TO MUCOUS MEMBRANES AND UPPER R ESPIRATORY TRACT. EXPOSURE CAN
CAUSE NAUSEA, DIZZINESS AND HEADACHE, GI DISTURBANCES, DERMATITIS.
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:NARCOTIC EFFECT. TARGET ORGANS:CENTRAL
NERVOUS SYSTEM.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT
LEAST 15 MINUTES. SKIN:IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF
WATER FOR AT LEAST 15 MINUTES WHILE REMOVING CONTAMINATED CLOTHING
AND SHOES . WASH CONTAMINATED CLOTHING BEFORE REUSE. INHAL:MOVE TO
FRESH AIR. IF NOT BREATHING GIVE ARTF RESP. IF BREATHING DIFFICULT
GIVE O*2. INGEST:WASH OUT MOUTH W/WATER IF PERSON CONSCIOUS. CALL
MD.
===================== Fire Fighting Measures =====================
Flash Point:26.0F,-3.3C
Lower Limits:1.8%
Upper Limits:10.1%
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL POWDER OR
APPROPRIATE FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:DANGER. FLAMMABLE LIQUID. VAPOR MAY
TRAVEL CONSIDERABLE DISTANCE TO SOURCE OF IGNITION AND FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:SHUT OFF ALL SOURCES OF IGNITION. EVACUATE
AREA. WEAR NIOSH/MSHA APPROVED SCBA, RUBBER BOOTS & HEAVY RUBBER
FOR DISP. VENT AREA & WAS H SPILL SITE AFTER MATERIAL PICKUP IS
COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL DRY PLACE. KEEP
TIGHTLY CLOSED. KEEEP AWAY FROM HEAT, SPARKS AND OPEN FLAME.
Other Precautions:DO NOT BREATHE VAPOR. AVOID CONTACT WITH EYES, SKIN
AND CLOTHING. AVOID PROLONGED OR REPEATED EXPOSURE. SEVERE EYE
IRRITANT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NOISH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH. PROTECTIVE
CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:176F,80C
Melt/Freeze Pt:M.P/F.P Text:-125F,-87C
Vapor Pres:71 @ 20C
Vapor Density:2.49
Spec Gravity:0.805
Appearance and Odor:COLORLESS LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, BASES, STRONG REDUCING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER BUT EXERT EXTRA CARE IN IGNITING AS
MATERIAL IS HIGHLY FLAMMABLE. DISPOSAL MUST BE IN ACCORDANCE WITH
LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:GC-408 CLASS B
CAGE:04011
CAGE:04011
============= Composition/Information on Ingredients =============
Ingred Name:POLYSULFIDE
Fraction by Wt: 70%
Ingred Name:CALCIUM CARBONATE (MARBLE) (LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 25%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9192
Ingred Name:MANGANESE DIOXIDE (AS MANGANESE)
CAS:1313-13-9
RTECS #:OP0350000
OSHA PEL:C,5 MG/M3/1 FUME TWA
ACGIH TLV:5 MG/M3 DUST/1 FUME
Ingred Name:THIRAM (SARA III)
CAS:137-26-8
RTECS #:JO1400000
Fraction by Wt: <3.0%
OSHA PEL:5 MG/M3
ACGIH TLV:1 MG/M3; 9192
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
Effects of Overexposure:MAY CAUSE SKIN OR EYE IRRITATION UPON CONTACT
======================= First Aid Measures =======================
First Aid:WASH HANDS THOROUGHLY. FLUSH EYES COPIOUSLY W/WATER. GIVE
EMETIC IF INGESTED.
===================== Fire Fighting Measures =====================
Flash Point:400F 0C
Extinguishing Media:WATER, CO*2, FOAM, DRY CHEMICALS
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:MFR RECM SCRAPE UP & CLEAN W/ SOLVENTS
======================Handling and Storage ======================
Handling and Storage Precautions:WASH HANDS THOROUGHLY AFTER
HANDLING.DO NOT INGEST. STORE INDOORS BELOW 80F.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Ventilation:SUFFICIENT
Other Protective Equipment:NONE
Supplemental Safety and Health
DRYING TIME VARIES FROM 1/2 HOUR TO 20 HOURS DEPENDING ON THE AMT OF
MNO*2 ADDED TO THE PRODUCT. % VOLATILE BY VOL: <0.2.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.5
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OFF WHITE TO GRAY SEMI-SOLID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES & OXIDIZING AGENTS
Stability Condition to Avoid:STORE BELOW 80F
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IAW FED., STATE & LOCAL CODES.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: POLYTONE WHITE AND TINT BASE, 071-0001
Cage: 42590
=======================================================
Contractor Summary
=======================================================
Cage: 42590
=======================================================
Ingredients
=======================================================
Cas: 107-21-1
RTECS #: KW2975000
% Wt: 2
OSHA PEL: N/K (FP N)
ACGIH TLV: C 50 PPM, VAPOR
EPA Rpt Qty: 1 LB
DOT Rpt Qty: 1 LB
------------------------------
Cas: 68855-54-9
% Wt: <5.0
OSHA PEL: N/K (FP N)
ACGIH TLV: 1.9 PPM (MFR)
------------------------------
Cas: 1332-58-7
RTECS #: GF1670500
% Wt: 5
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 2 MG/M3 TDUST
------------------------------
Cas: 14807-96-6
RTECS #: WW2710000
HYDRATE)
% Wt: <5.0
OSHA PEL: 20 MPPCF Z-3
ACGIH TLV: 2 MG/M3 RDUST
------------------------------
Cas: 14808-60-7
RTECS #: VV7330000
% Wt: <5.0
OSHA PEL: N/K (FP N)
ACGIH TLV: 0.1 MG/M3 RDUST
------------------------------
Cas: 25265-77-4
RTECS #: UF6000000
(ESTER ALCOHOL) VP: 1.0 @ 189F
% Wt: <5.0
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
RTECS #: 9999999VO
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: ACUTE: INHALATION: ADVERSE EFFECTS FROM VAPORS OR SPRAY
MISTS IN POORLY VENTILATED AREAS MAY INCLUDE IRRITATION OF THE MUCOUS
MEMBRANES OF THE NOSE, THROAT, AND RESPIRATORY TRACT AND SYMPTOMS OF HEADA
CHE AND NAUSEA. EYES: IN DIRECT CONTACT, MAY CAUSE IRRITATION. SKIN:
PROLONGED AND REPEATED CONTACT (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: SILICA, CRYSTALLINE-QUARTZ: IARC MONOGRAPHS,
SUPPLEMENT, VOL 7, PG 341, 1987: GROUP 2A. NTP 7TH ANNUAL REPORT (SUP DAT)
Signs And Symptions Of Overexposure: HTLH HAZ: WITH PRODUCT MAY CAUSE
IRRITATION. SKIN ABSORPTION: REDNESS, DRYING OF SKIN, OR OTHER SIGNS OF
IRRITATION OR CONTACT DERMATITIS. INGESTION: CAN CAUSE GASTROINTESTINAL
IRRITATION, NAUSEA, VOM ITING, AND DIARRHEA. CHRONIC: NONE SPECIFIED BY
MANUFACTURER.
Medical Cond Aggravated By Exposure: NONE.
First Aid: INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH IMMEDIATELY WITH LARGE
AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. TAKE TO MD FOR MEDICAL ATTENTION.
SKIN: REMOVE WITH SOAP AND WATER. REMOVE ALL CONTAMINATE D CLOTHING.
INGESTION: DRINK 1 OR 2 GLASSES OF WATER TO DILUTE. DO NOT INDUCE VOMITING.
CONSULT MD OR POISON CONTROL CENTER IMMEDIATELY. TREAT SYMPTOMATICALLY.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: DIKE, CONTAIN, OR ABSORB WITH INERT MATERIAL (I.E.
SAND, VERMICULITE, ETC). TRANSFER TO CONTAINERS FOR RECOVERY OR DISPOSAL.
PREVENT RUNOFF INTO SEWERS, STREAMS, OR OTHER BODIES OF WATER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE AND
FEDERAL REGULATIONS.
Handling And Storage Precautions: DO NOT EXPOSE TO EXTREMES IN TEMPERATURES.
AVOID EXPOSURE TO HIGH TEMPERATURES. DO NOT ALLOW TO FREEZE.
Other Precautions: DO NOT TAKE INTERNALLY. AVOID PROLONGED OR REPEATED EXPOSURE
TO LEVELS ABOVE TLV.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point Text: 241F,116C
Lower Limits: 0.6%
Upper Limits: 4.2%
Extinguishing Media: USE FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures: COOL CONTAINERS WITH WATER SPRAY. WEAR NIOSH/MSHA
APPROVED SCBA & FULL PROTECTIVE EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: CLOSED CONTAINERS EXPOSED TO HIGH TEMPERATURES
MAY EXPLODE OR BURST DUE TO BUILD UP OF STEAM PRESSURE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT NORMALLY REQUIRED. IF TLV IS EXCEEDED, USE
NIOSH/MSHA APPROVED ORGANIC VAPOR AND MIST PROTECTION.
Ventilation: USE ADEQUATE MECHANICAL (GENERAL AND/OR LOCAL) VENTILATION TO
MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment: WEAR IMPERVIOUS CLOTHING. EMERGENCY EYEWASH &
DELUGE SHOWER MEETING ANSI DESIGN CRITERIA (FP N).
Work Hygienic Practices: WASH HANDS BEFORE EATING OR USING RESTROOMS. REMOVE
AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health: CARCIN EXPLAN: ON CARCINOGENS, 1994:
ANTICIPATED TO BE CARCINOGEN.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >379F,>193C
Vapor Pres: SEE INGS
Vapor Density: LTR/AIR
Spec Gravity: 1.4 (H*2O=1)
Evaporation Rate & Reference: SLOWER THAN ETHER
Solubility in Water: COMPLETE
Appearance and Odor: TYPICAL FOR WATER BASED LATEX COATING
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE.
Materials To Avoid: AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: MAY FORM TOXIC MATERIALS, CARBON DIOXIDE,
CARBON MONOXIDE, ETC.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: POLYTONE WHITE AND TINT BASE, 071-0001
Cage: 42590
Company Name: DECRATREND PAINT CORP
Street: 251 MASON WAY
Zipcode: 91746
Label Required IND: Y
Date Of Label Review: 11/21/1995
Status Code: C
Label Date: 11/21/1995
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: DO NOT INGEST. ACUTE: INHALATION: ADVERSE EFFECTS FROM
VAPORS OR SPRAY MISTS IN POORLY VENTILATED AREAS MAY INCLUDE IRRITATION OF
THE MUCOUS MEMBRANES OF THE NOSE, THROAT, AND RESPIRATORY TRACT AND SY MPTOMS
OF HEADACHE AND NAUSEA. EYES: INDIRECT CONTACT, MAY CAUSE IRRITATION. SKIN:
PROLONGED AND REPEATED CONTACT MAY CAUSE IRRITATION. SKIN ABSORPTION:REDNESS,
DRYING, IRRITATION, DERMATITIS. INGESTI ON:GASTROINTESTINAL IRRITATION,
NAUSEA, VOMITING AND DIARRHEA. CHRONIC:CANCER HAZARD. CONTAINS CRYSTALLINE
SILICA QUARTZ WHICH IS LISTED AS AN ANIMAL LUNG CARCINOGEN (FP N).
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TURFOOD REGULAR 10-6-4
CAGE:31024
CAGE:31024
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM CHLORIDE
CAS:7447-40-7
RTECS #:TS8050000
Ingred Name:AMMONIUM SULFATE (SOLUTION) (SARA III)
CAS:7783-20-2
RTECS #:BS4500000
Ingred Name:AMMONIUM NITRATE (SOLUTION) (SARA III)
CAS:6484-52-2
RTECS #:BR9050000
Fraction by Wt: 8%
Ingred Name:AMMONIUM PHOSPHATE
RTECS #:BS3850000
Ingred Name:CALCIUM PHOSPHATES
CAS:1305-99-3
RTECS #:EW3870000
===================== Hazards Identification =====================
Effects of Overexposure:EYE/SKIN: IRRITATION.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH WITH WATER 15 MIN,CONSULT PHYSICIAN. SKIN: WASH
WITH SOAP AND WATER. INGESTION: DRINK LARGE QUANTITIES OF
WATER,INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER FOG
Fire Fighting Procedures:SELF-CONT BREATH APP,FULL PROTECTIVE CLOTHING.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP AND REPACKAGE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN DRY PLACE TO PREVENT MOISTURE
ABSORPTION AND POTENTIAL CAKING OF FERTILIZER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN.
Ventilation:MECHANICAL/GENERAL
Supplemental Safety and Health
ADD INGRED: LIMESTONE
================== Physical/Chemical Properties ==================
Spec Gravity:1
Solubility in Water:MODERATE
Appearance and Odor:GREYISH MIX OF FERTILIZER PARTICLES.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MODERATELY CORROSIVE TO METALS WHEN WET.
Hazardous Decomposition Products:AMMONIA & OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:AS A FERTILIZER MAY BE APPLIED TO SOIL IN
ACCORDANCE WITH LABEL RECOMMENDATIONS OR SMALL AMOUNTS TO NORMAL
APPROVED SOLIDS WASTES DISPOSAL SYSTEMS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:AEROSOL OS SURFACE ACTIVE AGENT
CAGE:06404
CAGE:06404
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM ISOPROPYLNAPHTANLENE SULFONATE
===================== Hazards Identification =====================
Effects of Overexposure:DUST CAUSES IRRIT OF EYES, NOSE/THROAT
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/PLENTY OF WATER AT LEAST 15 MIN, GET MD.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP, PLACE IN WASTE DISPOSAL CNTNR. FLUSH
AREA W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:PROD IS HYGROSCOPIC ABOVE 65%
HUMIDITY. KEEP IN DRY, CLOSED CNTNR.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE APPROVED RESP IF THERE EXCESS DUST
Ventilation:LOCAL EXH PREFERABLE, MECH EXH ACCEPTABLE
Other Protective Equipment:EYE WASH FOUNTAIN
Supplemental Safety and Health
MFR INDICATES PROD CONTAINS NO HAZ INGRED
================== Physical/Chemical Properties ==================
Spec Gravity:1.43
Solubility in Water:APPRECIABLE
Appearance and Odor:WHITE/LIGHT-CREAM, POWDER, MILD NAPHTHENIC ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIC
Hazardous Decomposition Products:CARBON MONOXIDE &/OR CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL IAW LOCAL, STATE, FED REG
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:1722 CB-150
Preparer's Name:R C JENTE
CAGE:OB1W3
CAGE:OB1W3
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
Ingred Name:PHOSPHATE
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/COOL WATER FOR 15 MINS. SKIN: FLUSH AREA.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE AREA TO CONTAIN AS MUCH OF MATERIAL AS
POSSIBLE. REMOVE ANY REMAINING MATERIAL BY ABSORBING ON
VERMICULITE/OTHER SUITABLE MATERIAL & PLACE IN A SEALED CONTAINER
FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. EXERCISE
CAUTION IN THE STORAGE & HANDLING OF ALL CHEMICAL SUBSTANCES.
Other Precautions:READ & OBSERVE LABEL PRECAUTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED
Ventilation:NORMAL
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F
Vapor Pres:LIKE WATER
Vapor Density:LIKE WATER
Spec Gravity:1.17
pH:6
Solubility in Water:COMPLETE
Appearance and Odor:WHITE LIQUID
Percent Volatiles by Volume:80
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH W/PLENTY OF WATER. DISPOSE OF IAW/LOCAL,
STATE & FEDERAL REGULATIONS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:365-371 COLORSET
Preparer's Name:DICK KARBO
CAGE:KMADD
CAGE:KMADD
============= Composition/Information on Ingredients =============
Ingred Name:COPPER COMPOUND
Fraction by Wt: 4%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED CONTACT W/SKIN/EYES CAN
CAUSE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMEDIATELY W/WATER. SKIN: WASH AFFECTED AREA
W/SOAP & WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>200F
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: WIPE UP & STORE WIPERS IN UNDERWRITERS
APPROVED CONTAINERS. LARGE: SCOOP MATERIAL INTO SEALABLE
CONTAINERS. WIPE UP REMAINDER & STORE WIPERS IN UNDERWRITERS
APPROVED CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS.
Other Precautions:AVOID CONTACT W/SKIN, EYES & CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS REQUIRED
Ventilation:LOCAL EXHAUST
Work Hygienic Practices:WASH AFTER USE. REMOVE/LAUNDER CONTAMINATED
CLOTHING BEFORE REUSE. DON'T CONSUME FOOD/BEVERAGE WHERE PRODUCT IS
USED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:470-610F
Evaporation Rate & Reference:SLOWER THAN WATER
Solubility in Water:INSOLUBLE
Appearance and Odor:OILY
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BLACK-BROWN, UTR-SHEET/ANGLE/CHANNEL/& TUBE
Preparer's Name:A.L. LOTT
CAGE:02329
CAGE:02329
============= Composition/Information on Ingredients =============
Ingred Name:ING 13:OF RECOM PRACTICES" PUBLISHED BY ACGIH COMMITTEE ON
INDUSTRIAL VENT, P.O. BOX 16153, LANSING MI 48910.
RTECS #:9999999ZZ
Ingred Name:ALUMINUM HYDROXIDE; (ALUMINA TRIHYDRATE). PEL: 15 MG/M3
TDUST; 5 MG/M3 RDUST. PEL & TLV AS AL.
CAS:21645-51-2
RTECS #:BD0940000
Fraction by Wt: 39-48%
OSHA PEL:SEE INGREDIENT NAME
ACGIH TLV:10 MG/M3
Ingred Name:UNSATURATED POLYESTER RESIN (POLYMERIZED)
Fraction by Wt: 25-36%
Ingred Name:FIBROUS GLASS; (FIBERGLASS)
RTECS #:LK3651000
Fraction by Wt: 20-30%
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:10 MG/M3
Ingred Name:ZINC STEARATE. PEL: 10 MG/M3 TDUST; 5 MG/M3 RDUST
CAS:557-05-1
RTECS #:ZH5200000
Fraction by Wt: >1%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:CHROMIUM, I0N (CR 3+)
CAS:16065-83-1
RTECS #:GB6261000
OSHA PEL:0.5 MG/M3
ACGIH TLV:0.5 MG/M3
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
OSHA PEL:10 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:TITANIUM
CAS:7440-32-6
RTECS #:XR1700000
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:SUPP DATA:TO EYES, MUC MEMB, & RESP TRACT. INHAL OF HIGH
CONC OF IRON OXIDE DUSTS OVER PRLNG PERIODS OF TIME (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:MAY CAUSE BENIGN PNEUMOCONIOSIS. TITANIUM DIOXIDE IS
OF LOW TOX. PRLNG EXPOSURE ABOVE RECOM EXPOS LIM MAY (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:PRDCE A BENIGN PNEUMOCONIOSIS.
RTECS #:9999999ZZ
Ingred Name:RESP PROT: CONSULT YOUR RESP EQUIP SUPPLIER FOR SELECTION
OF THE PROPER EQUIPMENT.
RTECS #:9999999ZZ
Ingred Name:VENT: DESIGN DETAILS FOR LOC EXHAUST VENT SYS MAY BE FOUND
IN LATEST EDITION OF "INDUST VENT: MANUAL OF RECOM (ING 14)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IN ITS MFR & SHIPPED ST, MATL IS
CONSIDERED NON-HAZ. PROCESSING, HOWEVER, MAY GENERATE PARTICULATE
MATTER. ACUTE: DUSTS GENERATED DURING MECH PROCESSING MAY BE
IRRITATING TO EYES/MUC MEMB/RESP TRACT, & SKIN. CHRONIC:
W/EXCEPTION OF METALS CNTND IN PIGMENTS, DUSTS GENERATED DURING
MECH PROCESSING OF (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:THESE PROD ARE NOT EXPECTED TO PRDCE
ANY LONG TERM/CHRONIC HLTH EFTS. PRLNG EXPOS TO DUSTS GENERATE
DURING MECH PROCESSING MAY POSS AGGRAVATE PRE-EXISTING LUNG CNDTNS
SUCH AS EMPHYSEMA. CARBO N BLACK:THERE ARE NO HLTH HAZ TO HUMAN
FROM EXPOS TO CARBON BLACK ALTHOUGH THERE IS SOME SLIGHT EVIDENCE
THAT(SUPP DATA)
Medical Cond Aggravated by Exposure:PRE-EXISTING LUNG CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. IF BRTHG IS DFCLT/HAS STOPPED,
ADMINISTER O2/ARTF RESP AS INDICATED. SEEK MED ATTN. EYE: FLUSH
W/H2O FOR @ LST 15 MIN. IF IRRIT DEVELOPS/PERSISTS, SEEK MED ATTN.
SKIN: WASHWITH MILD SOAP AND WATER. IF IRRIT DEVELOPS/PERSISTS,
SEEK MED ATTN. DERMATITIS SHOULD BE TREATED BY PHYS. INGEST: SEEK
MED ATTN.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE WATER SPRAY, CO2, OR DRY CHEMICAL MEANS TO
EXTINGUISH FIRES.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
CONTR OF MATL IN/NEAR FIRES SHOULD BE COOLED W/H2O SPRAY/FOG.
Unusual Fire/Explosion Hazard:THERMAL DECOMP/COMBUSTION MAY PRDCE COX/
NOX, &/OR SOX AS WELL AS OTHER ORG SPECIES OF UNKNOWN COMPOSITION.
METAL FUMES FROM PIGMENTS MAY ALSO BE (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:GOOD HOUSEKEEPING PRACTICES SHOULD BE EMPLOYED
TO AVOID ACCUMULATION OF DUST. WET SWEEPING OR MOPPING IS A
PREFERRED CLEAN UP METHOD TO PREVENT RESUSPENSION OF DUSTS INTO
ATMOSPHERE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL HANDLING OR STORAGE
PRECAUTIONS ARE NECESSARY. PROTECTION FROM THE ELEMENTS IS
DESIRABLE.
Other Precautions:ALL CHEMICALS SHOULD BE HANDLED SO AS TO PREVENT EYE
CONTACT AND EXCESSIVE OR REPEATED SKIN CONTACT. APPROPRIATE EYE AND
SKIN PROTECTION SHOULD BE EMPLOYED. INHALATION OF DUSTS & VAPORS
SHOULD BE AVOI DED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR EXPOS IN EXCESS OF THOSE CITED IN INGRED
SECTION, BY <FACTOR OF 10, USE AS A MINIMUM NIOSH/MSHA APPRVD RESP
W/ CARTRIDGE FOR DUSTS & FUMES W/AN EXPOS LIM OF NOT <0.05MG/KG. IF
EXPOS TO PARTICULATE MATTER MAY EXCEED 10X CITED LIM,(ING 12
Ventilation:DURING PROCESSING, NATL/LOC EXHAUST VENT SHOULD BE PROVIDED
TO MAINTAIN EXPOS BELOW LIM CITED IN INGRED SECT. (ING 13)
Other Protective Equipment:PROTECTIVE APRON/COVERALLS MAY BE DESIRABLE
TO PVNT BUILDUP OF DUSTS ON WORK CLOTHES OR SKIN.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
% VOLAT:NOT VOLATILE. EXPLO HAZ: REL DURING COMBUSTION. EFTS OF
OVEREXP: EXCESS EXPOS CAN LEAD TO DECR IN PULM FUNC W/ POSS CARDIAC
INVOLVEMENT. CONC ABOVE RECOM EXPOS CAN BE IRRITATING TO EYES/ MUC
M EMB & RESP TRACT. CHROMIUM (III) CAN CAUSE DERMATITIS & ALLERGIC
SENSITIZATION. IRON OXIDE DUSTS CAN BE IRRITATING (ING
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.7-2.2
Solubility in Water:INSOLUBLE
Appearance and Odor:SHEET OF VARIOUS COLORS
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS MAY LIBERATE HYDROGEN SULFIDE IF SULFIDE CNTNG PIGMENTS
ARE PRESENT. STRONG OXIDIZING & REDUCING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:COX, NOX, SOX & OTHER ORGANIC SPECIES
OF UNKNOWN COMPOSITION. THESE WOULD BE EXPECTED ONLY UNDER EMER
CONDITIONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:MATERIAL SHOULD BE DISPOSED OF IN A LANDFILL
WITH ALL APPLICABLE LOCAL, STATE, AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:521-01 WHITE BASE SILATHANE INT/EXT BRUTONEINTERIOR ALKYD SE
CAGE:EO376
CAGE:EO376
CAGE:85520
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS
*96-4*
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 25-50%
Other REC Limits:525 MG/CUM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE *96-4*
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 0-5%
OSHA PEL:2 MG/CUM (RESP DUST)
ACGIH TLV:2 MG/CUM (RESP DUST)
Ingred Name:MEDIUM ALIPHATIC NAPHTHA (AROMATIC 100), PARAFFIN-NAPTHANES
MINERAL SPIRITS *96-4*
CAS:64742-88-7
Fraction by Wt: 0-5%
Other REC Limits:100 PPM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:VOLATILE ORGANIC CONTENT: 3.32 TO 3.74 LBS/GAL
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE NOSE, THROAT & EYE
IRRITATION. REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE
PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DIZZINESS, HEADACHE, INTOXICATION,
EUPHORIA, UNCONSCIOUSNESS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LUKE WARM WATER FOR 15 MINS. SKIN: FLUSH WASH
W/COPIOUS AMOUNTS OF LUKE WARM WATER. INHALATION: REMOVE TO FRESH
AIR. RESTORE BREATHING IF REQUIRED. INGESTION: RINSE MOUTH
IMMEDIATELY. GI VE 6-8 OUNCES OF LIQUID. NEVER GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS PERSON. DON'T INDUCE VOMITING UNLESS
ADVISED BY A PHYSICIAN. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:104F
Lower Limits:0.9
Upper Limits:7
Extinguishing Media:THE NFPA CLASS B EXTINGUISHER.
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. WATER MAY BE
USED TO COOL CLOSED CONTAINERS. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. DON'T APPLY TO HOT SURFACES. NEVER USE
WELDING/CUTTING TORCH ON/NEAR CONTAINER, MAY IGNITE/EXPLODE.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP &/CONTAIN DISCHARGE SAFELY. KEEP SOURCES
OF IGNITION AWAY. VENTILATE AREA. USE NON-SPARKING TOOLS. COVER
W/INERT MATERIAL. KEEP OUT OF DRAINS, SEWERS/WATERWAYS. CONTACT
FIRE AUTHORITIES. NOTIFY L OCAL HEALTH & POLLUTION CONTROL
AGENCIES.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE >120F. DON'T CUT/PUNCTURE
CONTAINER. DON'T WELD NEAR CONTAINER. KEEP CONTAINER TIGHTLY CLOSED
WHEN NOT IN USE. USE W/ADEQUATE VENTILATION.
Other Precautions:GROUND CONTAINERS WHEN POURING & LIMIT FREE-FALL TO A
FEW INCHES. AVOID CONTAMINATED RAGS/IGNITABLE ORGANIC MATERIALS.
INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING & INHALING THE
CONTENTS MAY BE H ARMFUL/FATAL. DON'T BREATHE VAPORS/MIST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN OPEN AREAS DURING SPRAY APPLICATION, USE
NIOSH/MSHA MECHANICAL FILTER RESPIRATOR/IN RESTRICTED AREAS, USE
NIOSH/MSHA APPROVED CHEMICAL MECHANICAL FILTERS/IN CONFINED AREAS,
USE NIOSH/MSHA APPROVED AIR LINE TYPE RESPIRATORS/HOODS.
Ventilation:GENERAL DILUTION/LOCAL EXHAUST TO KEEP TLV BELOW ACCEPTABLE
LIMIT DURING WELDING/FLAME CUTTING ON COATED SURFACES.
Other Protective Equipment:APRON
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS THOROUGHLY BEFORE EATING & USING WASHROOM.
Supplemental Safety and Health
% VOLATILE BY VOLUME: 50.96-57.73.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:300-416F
Vapor Pres:2
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN BU AC
Percent Volatiles by Volume:(SUPP)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WELDING
Stability Condition to Avoid:SPARKS, OPEN FLAME, HOT SURFACES, SOURCES
OF IGNITION.
Hazardous Decomposition Products:CO, CO2 & OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T FLUSH TO SEWER, WATERSHED/WATERWAY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TOUCHDOWN 710
CAGE:GO724
CAGE:GO724
CAGE:0LE45
============= Composition/Information on Ingredients =============
Ingred Name:METHANOL (METHYL ALCOHOL), COLUMBIAN SPIRITS *98-2*
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 4%
Other REC Limits:200 PPM
OSHA PEL:200 PPM
ACGIH TLV:200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:AMMONIA, AMMONIUM HYDROXIDE-ANHYDROUS, ANHYDROUS AMMONIA
CAS:7664-41-7
RTECS #:BO0875000
Fraction by Wt: 1%
Other REC Limits:25 PPM
OSHA PEL:35 MG/CUM
ACGIH TLV:17 MG/CUM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:VOLATILE ORGANIC CONTENT: 54 GM/L COATING; (36 GM/L
MATERIAL)
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY IRRITATE MUCOUS
MEMBRANES. EYES/SKIN: MAY CAUSE IRRITATION. OVEREXPOSURE MAY CAUSE
CENTRAL NERVOUS SYSTEM DEPRESSION. MAY CAUSE DERMATITIS. INGESTION:
MAY CAUSE CHEMICAL PNEUMONITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NAUSEA, DROWSINESS, IRRITATION, RASH, VOMITING,
HEADACHE, NARCOSIS, UNCONSCIOUSNESS
======================= First Aid Measures =======================
First Aid:EYES: WASH W/WATER. SKIN: REMOVE FROM SKIN & APPLY SKIN
CREAM. INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN IF NECESSARY.
INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Extinguishing Media:WATER SPRAY, FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS.
================== Accidental Release Measures ==================
Spill Release Procedures:IF TLV IS EXCEEDED, USE SELF CONTAINED
BREATHING APPARATUS. SOAK UP MATERIAL W/SAWDUST/VERMICULITE & PLACE
INTO CLOSED CONTAINERS FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT AGAINST PHYSICAL DAMAGE. STORE
IN A COOL PLACE. USE W/ADEQUATE VENTILATION. KEEP OUT OF REACH OF
CHILDREN.
Other Precautions:AVOID BREATHING BUILDUP OF VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNLESS EXPOSURE IS OVER TLV. USE
NIOSH APPROVED RESPIRATOR. USE PRODUCT IN WELL VENTILATED AREA.
Ventilation:SUFFICIENT TO KEEP WORKPLACE CONCENTRATION BELOW TLV. USE
MECHANICAL EXHAUST IF TLV IS EXCEEDED.
Other Protective Equipment:NEOPRENE APRON
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Vapor Density:>1
Spec Gravity:0.7-0.9
Evaporation Rate & Reference:(N-BUTYL ACETATE=1): >1
Solubility in Water:DILUTABLE
Appearance and Odor:THIN MILKY COLORED SOLUTION W/STRONG AMMONIA ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS
Stability Condition to Avoid:OPEN FLAME, ELECTRIC ARCS, HOT SURFACES
Hazardous Decomposition Products:HYDROGEN CHLORIDE, PHOSGENE GAS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CLEANER FLUID, PRODUCT CODE:16-472
Preparer's Name:MARLO CARTER
CAGE:17124
CAGE:17124
============= Composition/Information on Ingredients =============
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 6%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:350 PPM
ACGIH TLV:350 PPM/450STEL;9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:ACETONE (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 25%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:750PPM/1000STEL;9294
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM; Z-2
ACGIH TLV:S, 50 PPM; 9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ALIPHATIC SOLVENT, INGREDS #5 & 6.
Fraction by Wt: 49%
Other REC Limits:NONE RECOMMENDED
Ingred Name:CYCLOHEXANE (SARA III)
CAS:110-82-7
RTECS #:GU6300000
Fraction by Wt: 0-3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:300 PPM
ACGIH TLV:300 PPM, 9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 1-6%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM; Z-2
ACGIH TLV:S, 50 PPM; 9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:METHYLCHLOROFORM PRIMARILY A CENTRAL
NERVOUS SYSTEM DEPRESSANT.IRRIT RESP
SYS,DIZZ,NAU,LIGHTHEADEDNESS,HEAD,LOSS OF
COORDINATION/EQUILIBRIUM,UNCONSC,CNS DAMAGE,DEATH.VENTRICULAT
FIBRILLATION.EYE DISCO MFORT,PAIN,IRRIT.SKIN IRRIT,DERM.IRRIT OF
MOUTH & GI TRACT,VOMIT,ASPIRATION INTO LUNGS LEAD TO CHEM
PNEUMONI,PULM EDEMA.
Explanation of Carcinogenicity:PER MSDS:CONTAINS METHYLCHLOROFORM.
Effects of Overexposure:CNS DEPRESSANT.RESP SYS
IRRIT,DIZZ,NAU,LIGHTHEADEDNESS,HEAD,LOSS OF
COORDINATION,EQUILIBRIUM,UNCONSC,DEATH.EYE:DISCOMFORT,PAIN,IRRIT,DE
RM.INGEST:MOUTH/GI TRACT IRRIT,VOMIT,ASPIRATION INTO LUNGS MAY LE
AD TO CHEM PNEUMONIA,PULM EDEMA.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:HAVE PHYSICIAN CALL LOS ANGELES POISON INFO CNTR
800-356-3129.INHAL:REMOVE TO FRESH AIR.NOT BREATH GIVE ART RESP
PREFERABLY MOUTH-TO-MOUTH.BREATH DIFF GIVE OXY.CALL
PHYSICIAN.EYE/SKIN:FLUSH EYE/SKIN W /PLENTY OF WATER(SOAP/WATER FOR
SKIN)FOR @LEAST 15MINS WHILE REMOVING CONTAMIN CLOTH/SHOES.IRRIT
OCCUR CALL PHYSICIAN.INGEST:IF CONSC DRINK LG QUANT OF WATER.DO NOT
INDUCE VOMIT.TAKE IMMED TO (SUPPLE)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:0F,-18C
Lower Limits:1.0
Extinguishing Media:FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED
PRESSURE-DEMAND,SELF-CONTAINED BREATHING APPARATUS FOR POSSIBLE
EXPO TO HYDROGEN CHLORIDE & POSSIBLE TRACES OF PHOSGENE.
Unusual Fire/Explosion Hazard:HIGHLY VOLATILE/READILY GIVES OFF VAP
WHICH MAY TRAVEL ALONG GROUND.MAY BE MOVED BY VENTI & IGN BY PILOT
LIGHTS/OTHER FLAMES/ETC @LOCATIONS DISTANT FRM HNDL PT.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE.MAX VENTILATION.DIKE/CONTAIN.RECOVER
ON ABSORBENTS(SAWDUST,VERMI)SWEEP INTO CLSD CNTNR FOR DISPOSAL.AFT
ALL VISIBLE TRACES/IGN VAP HAVE BEEN REMOVE WET VACUUM WELL AREA.DO
NOT FLUSH TO SEWER. IF SURFACE POROUS REMOVE & DISPOSE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T USE IN POORLY VENTI/CONF SPACES
W/O PROPER RESP PROT.METHYLCHLOROFORM VAP HEAVIER THAN AIR;WILL
COLLECT IN LOW AREA.KEEP CNTNR CLSD WHEN NOT USE
Other Precautions:STORE ONLY IN CLSD PROPERLY LABELED CNTNRS.LIQ
OXY/OTHER STRONG OXIDANTS MAY FORM EXPLO MIXTURES
W/METHYLCHLOROFORM.MATL/VAP IN CONTACT W/FLAMES/HOT GLOWING
SURFACES/ELECT ACR DECOMPOSE TO HCL GAS/TRA CE OF PHOSGENE.DO NOT
USE W/AL.(SUPPLE)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE HALF/FULL FACEPC ORG VAP CHEM
CARTRIDGE/CANISTER RESP WHEN CONC EXCEED PERMISS LIMITS.USE
SCBA/FULL FACEPC AIRLINE RESP W/AUX SCBA IN PRESS-DEMAND MODE FOR
EMERG/ALL WORK PERFORMED IN STORAGE VESS /CONFINED AREAS.OSHA
29CFR1910.134.NIOSH
Ventilation:USE LOC EXHAUST OR DILUTION VENTI AS APPROPRIATE TO CONTROL
EXPOSURE TO BELOW PERMISSIBLE LIMITS.
SERVICE-DEGRADES INWATER.BOOTS,APRON,CHEM SUITS IAW 29CFR1910.133 &
29CFR1910.132.
Work Hygienic Practices:CLEAN WELL CONTAMIN CLOTH/SHOES BEF REUSE.WASH
HANDS AFTER HANDLING.
Supplemental Safety and Health
1STAID:HOSP/CALL DR.UNCONSC/CONVUL TAKE IMMED TO HOSP.INCREASED SENS OF
HEART TO ADRENALINE MAY BE CAUSED BY OVEREXPO TO
METHYLCHLOROFORM.NEVER ADMIN ADRENALIN FOLLOWING
METHYLCHLOROFORM.OTHER PREC:DO N'T USE CUT/WELD TORCHES ON MATL DR
UNLESS PROPERLY PURGE/CLEAN.DON'T BREATH VAP.USE ONLY W/ADEQ
VENTI.AVOID EYES/SKIN.
================== Physical/Chemical Properties ==================
HCC:F2
Vapor Density:>1
Spec Gravity:0.77
Evaporation Rate & Reference:>1, (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE.
Appearance and Odor:CLEAR LIQUID, SWEET ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID MIXING W/CAUSTIC SODA,CAUSTIC POTASH OR OXIDIZING MATL.SHOCK
SENSITIVE COMPOUNDS MAY FORM.AVOID CONTACT W/ALUMINU.
Stability Condition to Avoid:AVOID OPEN FLAMES, HOT GLOWING SURFACES OR
ELECTRIC ARCS. NOT SUITABLE FOR VAPOR DEGREASING.
Hazardous Decomposition Products:HYDROGEN CHLORIDE AND POSSIBLE TRACES
OF PHOSGENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSED OF CLEANUP MATL IN PERMITTED HAZ WASTE
MGMT FACILITY.LIQ REPROCESS/INCINERATE/TREATE IN PERMITTED HAZ
WASTE MGMT FACILITIY.AVOID ENVIRO CONTAMINATION WHEN DISPOSING
MATL.DISPOSE IAW ALL RELEV ANT LOC/STATE/FED REGS/LAWS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ROYCO 27
CAGE:07950
CAGE:66172
CAGE:6V632
CAGE:07950
============= Composition/Information on Ingredients =============
Ingred Name:SYNTHETIC ESTER
CAS:1330-86-5
Fraction by Wt: 75 - 85%
Other REC Limits:NONE RECOMMENDED
Ingred Name:LITHIUM 12 HYDROXYSTEARATE
CAS:7620-77-1
Fraction by Wt: 10 - 15%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ANTIMONY DIALKYLDITHIOCARBAMATE
CAS:15991-76-1
Fraction by Wt: 1 - 2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.5 MG SB/M3
ACGIH TLV:0.5 MG SB/M3
Ingred Name:P,P'-DIOCTYLDIPHENYLAMINE
CAS:68411-46-1
Fraction by Wt: 1 - 2%
Other REC Limits:NONE RECOMMENDED
Ingred Name:MINOR ADDITIVE
Fraction by Wt: <4%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN. ACUTE-
EYE:DIRECT CONTACT IRRITATES SLIGHTLY. SKIN:PROLONGED/REPEATED
CONTACT MAY CAUSE IRRITATION. INJECTION UNDER SKIN CAUSES LOCAL
NECROSIS. INHALE:VAPOR MAY IRRITATE RESPI RATORY TRACT. ORAL:SMALL
AMOUNTS SHOULDNOT INJURE. SWALLOWING LARGE AMOUNTS MAY BE HARMFUL.
CHRONIC- DERMATITIS.
Explanation of Carcinogenicity:NONE.
Effects of Overexposure:IRRITATION, REDNESS, SWELLING, TISSUE DAMAGE,
NAUSEA, VOMITING
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING SKIN
DISORDERS MAY BE MORE SUCCEPTIBLE TO THE EFFECTS FROM EXPOSURE TO
THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. EYES:FLUSH WITH WATER FOR 15 MINUTES. HOLD EYELIDS OPEN.
SKIN:WIPE OFF EXCESS & WASH SKIN WITH MILD SOAP & WATER OR
WATERLESS CLEANER . IF INJECTED UNDER SKIN, REGARDLESS OFITS SIZE,
CONTACT A PHYSICIAN IMMEDIATELY. DELAY MAY CAUSE LOSS OF AFFECTED
PART OF BODY. ORAL:DO NOT INDUCE VOMITING. CALL PHYSICIAN IF LARGE
AMOUNTS INGESTED.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL/CARBON DIOXIDE. DON'T
USE DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE
REIGNITED.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED OR CONFINED AREA
WITHOUT PROPER PROTECTIVE EQUIPMENT AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP UP EXCESS GREASE. PICK-UP RESIDUE WITH
NON-FLAMMABLE ABSORBENT MATERIAL SUCH AS DIATOMACEOUS EARTH, SAND
OR VERMICULITE. SWEEP UP AND TRANSFER TO A CONTAINER FOR PROPER
DISPOSAL. CLEAN AREA WITH MILD DETERGENT.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, VENTILATED PLACE,
AWAY FROM OXIDIZERS. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN
USE. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:DO NOT GET IN EYES. MINIMIZE SKIN CONTACT. WASH
THOROUGHLY AFTER HANDLING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. PROPERLY DISPOSE OF CONTAMINATED LEATHER ARTICLES INCLUDING
SHOES THAT CANNOT BE DECONTAMINATED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:ADEQUATE
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V6
NRC/State Lic Num:NOT RELEVANT
Solubility in Water:INSOLUBLE
Appearance and Odor:TAN, SMOOTH GREASE - SLIGHT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT, OPEN FLAME
Hazardous Decomposition Products:A COMPLEX MIXTURE OF AIRBORNE SOLID,
LIQUID, PARTICULATES & GASES WILL EVOVLE. CARBON MONOXIDE & OTHER
COMPD. MAY FORM.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. THIS PRODUCT IS CLASSIFIED AS AN OIL UNDER
SECTION 311 OF THE CLEAN WATER ACT. SPILLS THAT CAUSE A SHEEN MUST
BE REPORTED TO THENATIONAL RESPONSE CENTER, 800-424-8802.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MS2190 TEP (DURO 2190 TEP OIL)
CAGE:3T432
CAGE:3T432
CAGE:9V333
============= Composition/Information on Ingredients =============
Ingred Name:LUBRICATING OIL
ACGIH TLV:5 MG/CUM - MIST
===================== Hazards Identification =====================
Effects of Overexposure:SKIN IRRIT,DERMATITIS FROM PROLNGD/RPTD
CONTACT. SLIGHT EYE IRRIT RESULTS FROM CONTACT.
======================= First Aid Measures =======================
First Aid:EYE:IMMED FLUSH W/WATER AT LEAST 15 MINUTES. SKIN:REMOVE BY
WIPING,WASH SKIN W/PLENTY OF SOAP & WATER. INGESTION:IF LGE AMTS
INGESTED,GIVE QUANTITIES OF WATER,INDUCE VOMITING,CALL MD IMMED.
INHALATION :NOT EXPECTED TO BE A PROBLEM.
===================== Fire Fighting Measures =====================
Flash Point:>415F D92(COC)
Extinguishing Media:DRY CHEMICAL,CO*2. FOAM&WATER FOG EFFECTIVE,CAUSE
FROTHING.
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS IN
ENCLOSED/CONFINED AREA
Unusual Fire/Explosion Hazard:SLIGHTY COMBUSTIBLE.ABOVE FLASH
PT,FLAMMABLE VAPORS RELEASED(BURN/EXPLODE).MISTS/SPRAYS-FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:FLOOR MAY BE SLIPPERY. REMOVE ALL IGNITION
SOURCES. CLEAN UP SPILL AS SOON AS POSSIBLE. DIKE AREA AND USE
ABSORBENT MATERIAL SUCH AS CLAY,SAND,VERMICULITE OR DIATOMACEOUS
EARTH TO CLEAN UP SPILL. PLAC E IN CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM OPEN FLAMES. NO
SPLASHING CANNOT BE AVOIDED.
Other Precautions:USE GOOD PERSONAL HYGIENE PRACTICES. AVOID USING
SOLVENTS(GASOLINE,KEROSENE,ETC) AND HARSH ABRASIVE SKIN CLEANERS.
OIL-SOAKED CLOTHING SHOULD BE REMOVED PROMPTLY & LAUNDERED BEFORE
REUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMAL CONDITIONS-NONE. MISTS >TLV-USE
NIOSH/MSHA APPRVD EQUIPMENT.
Ventilation:USE ADEQUATE VENTILATION TO KEEP OIL MISTS BELOW TLV.
Other Protective Equipment:IMPERVIOUS APRONS&SLEEVES PROVIDED NOT AN
ACCIDENT HAZARD.
Supplemental Safety and Health
VAPOR PRESSURE:<0.1 MMHG.VOLATILE CHARACTERISTICS:NEGLIGIBLE.
AUTOIGNITION TEMP:APPROX 750 F. WASH SKIN CONTACT AREAS W/SOAP &
WATER BEFORE EATING AND AFTER COMPLETING WORK.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:IBP >600 F
Vapor Density:>10.
Spec Gravity:0.88
Evaporation Rate & Reference:>1 ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER-COLORED FLUID; SLIGHT LUBE OIL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS SUCH AS LIQUID CHLORINE AND OXYGEN.
Hazardous Decomposition Products:INCOMPLETE COMBUSTN-CO AND TRACE
OXIDES &/OR CMPDS OF S & N.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF CONTAMINATED MATERIAL IN AN APPROVED
DISPOSAL SITE. COMPLY W/LOCAL REGULATIONS CONCERNING WASTE DISPOSAL
INTO LANDFILLS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:THERMAL-ACOUSTICAL BATTS
CAGE:FO261
CAGE:FO261
CAGE:75165
============= Composition/Information on Ingredients =============
Ingred Name:GLASS OXIDE, FIBER GLASS WOOL, LEAD BOROSILICATE GLASS
ENAMEL FLUX
CAS:65997-17-3
Fraction by Wt: 85-98%
Ingred Name:PHENOL, UREA, FORMALDEHYDE RESIN
CAS:25104-55-6
Fraction by Wt: 2-15%
Ingred Name:KRAFT, FOIL/KRAFT, PSK, FSK, AND VARIOUS METAL BUILDING
FACINGS
Fraction by Wt: <1-6.7%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF THE UPPER
RESPIRATORY TRACT MAY OCCUR. SKIN/EYES: TEMPORARY IRRITATION.
INGESTION: MAY CAUSE TEMPORARY IRRITATION TO THE GI TRACT/STOMACH.
MAY AFFECT THE THROAT, LUNGS & SKIN /EYES.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, SCRATCHY THROAT, COUGHING,
CONGESTION, REDNESS, ITCHING
Medical Cond Aggravated by Exposure:PRE-EXISTING CHRONIC RESPIRATORY,
SKIN/EYE DISEASES/CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. DRINK WATER TO CLEAR THROAT
& BLOW NOSE TO REMOVE FIBERS & DUSTS. SKIN: WASH GENTLY W/SOAP &
WARM WATER TO REMOVE DUST & FIBERS. WASH HANDS BEFORE EATING/USING
THE RES TROOM. INGESTION: TREAT SYMPTOMATICALLY. RINSE MOUTH
W/WATER TO REMOVE FIBERS & DRINK PLENTY OF WATER. EYES: DON'T
RUB/SCRATCH. FLUSH W/LARGE AMOUNTS OF WATER FOR 5-15 MINS. (SEE
SUPP)
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, WATER, WATER FOG, DRY CHEMICAL
Fire Fighting Procedures:USE NORMAL FIRE FIGHTING PROCEDURES TO PREVENT
INHALATION OF SMOKE & GASES.
Unusual Fire/Explosion Hazard:NO POTENTIAL FOR FIRE/EXPLOSION.
================== Accidental Release Measures ==================
Spill Release Procedures:PICKUP LARGE PIECES. VACUUM DUSTS. IF SWEEPING
IS NECESSARY, USE A DUST SUPPRESANT SUCH AS WATER. DON'T DRY SWEEP
DUST ACCUMULATION/USE COMPRESSED AIR FOR CLEAN-UP. THESE PROCEDURS
WILL HELP TO MINIMI ZE POTENTIAL EXPOSURES.
======================Handling and Storage ======================
Handling and Storage Precautions:USE PROTECTIVE EQUIPMENT WHEN HANDLING
UNCONTAMINATED MATERIAL. WAREHOUSE STORAGE SHOULD BE IAW/PACKAGE
DIRECTIONS, IF ANY.
Other Precautions:KEEP DRY & PROTECT FROM ELEMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH APPROVED DUST/MIST RESPIRATOR(3M
9900 & MOLDEX 200)/EXPOSURE EXCEEDING TEN TIMES, A NIOSH APPROVED
HALF MASK RESPIRATOR W/HEPA FILTER CARTRIDGE(MSA COMFO II W/H
CARTRIDGES & THE SURVIVAIRHALF MASK W/#1090-00 CARTRIDGES.
Ventilation:LOCAL EXHAUST TO REMOVE AIRBORNE DUST & FIBERS. GENERAL
DILUTION: TO KEEP AIRBORNE DUST & FIBERS BELOW APPLICABLE LIMITS
Other Protective Equipment:BARRIER CREAMS, LOOSE FITTING, LONG SLEEVED
CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. USE A VACUUM CLEANER BEFORE REPAIR/MAINTENANCE TO REMOVE
DUST/FIBERS.
Supplemental Safety and Health
APPEARANCE CONT'D: GOLD TO YELLOW FIBROUS GLASS BOARD, BATT,
BLANKETT/LOOSE FILL INSULATION W/W/O KRAFT, FSK/OTHER FACINGS, NO
SIGNIFICANT ODOR. FIRST AID CONT'D: OBTAIN MEDICAL ATTENTION IN ALL
CASES .
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:1300F
Solubility in Water:INSOLUBLE
Appearance and Odor:(SEE SUPP)
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:PYROLYSIS/BURNING; OF THE RESIN
Hazardous Decomposition Products:CO2, CO, CARBON PARTICLES,
FORMALDEHYDE & TRACES OF HYDROGEN CYANIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SILVER ALLOY A
CAGE:59401
CAGE:59401
============= Composition/Information on Ingredients =============
Ingred Name:SILVER (SARA III)
CAS:7440-22-4
RTECS #:VW3500000
Fraction by Wt: 20-50%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.01 MG/M3
ACGIH TLV:0.1 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:COPPER (SARA III)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 15-45%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2MG/M3 FUME; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ZINC (SARA III)
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: 15.5-30%
Other REC Limits:5 MG/M3 AS OXIDE FUM
OSHA PEL:10 MG ZNO/M3
ACGIH TLV:10 MG ZNO/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 0-3%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SHORT TERM EXPOSURE TO WELDING FUMES,
GASES OR DUST MAY RESULT IN DISCOMFORT SUCH AS DIZZINESS, NAUSEA,
FEVER, DRYNESS AND/OR IRRITATION OF NOSE, THROAT AND EYES. SKIN
SENSITIVITY MAY ALSO BE NOTED. L ONG TERM EXPOSURE TO
FUMES/GASES/DUST MAY CAUSE PULMONARY IRRITATION OR PNEUMOCONIOSIS.
Explanation of Carcinogenicity:NICKEL IS CONSIDERED CARCINOGEN NTP AND
IARC. RESPIRATORY CANCER FROM WELDING/BRAZING IS UNCONFIRMED.
Effects of Overexposure:EXPOSURE TO WELDING/BRAZING FUMES MAY RESULT IN
DISCOMFORT SUCH AS DIZZINESS, NAUSEA, FEVER, DRYNESS AND/OR
IRRITATION OF NOSE, THROAT AND EYES. SKIN SENSITIVITY MAY ALSO BE
NOTED. WATERY EYES, HEADAC HE, BREATHING DIFFICULTY, FREQUENT
COUGHING AND/OR CHEST PAINS MAY OCCUR FROM ACUTE EXPOSURE. TOXIC
GASES CAN BE FATAL.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH IMPAIRED PULMONARY
FUNCTION OR ILLNESS MAY HAVE SYMPTOMS EXACERBATED BY IRRITANTS
CONTAINED IN WELDING FUMES.
======================= First Aid Measures =======================
First Aid:IN CASE OF ELECTRICAL SHOCK, TURN OFF POWER PRIOR TO REMOVAL
FROM EXPOSURE AREA AND ADMINISTRATION OF FIRST AID. REMOVE FROM
EXPOSURE AREA AND CALL FOR MEDICAL AID. ADMINISTER OXYGEN IF
BREATHING IS D IFFICULT. IF NOT BREATHING, BEGIN ARTIFICIAL
RESPIRATION. IF NO DETECTABLE PULSE, BEGIN EXTERNAL HEART MASSAGE.
EMPLOY FIRST AID TECHNIQUES RECOMMENDED BY THE AMERICAN RED CROSS.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE DRY CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:MAY PRODUCE HAZARDOUS METAL FUMES
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP ANY GRINDING DUST OR WASTE RESIDUES
AND PLACE IN SUITABLE DOT APPROVED CONTAINERS AND DISPOSE OF IN
FULL COMPLIANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS. AVOID
INHALATION AND SKIN EXPOSU RE.
======================Handling and Storage ======================
CLOTHING WHEN CUTTING, GRINDING OR WELDING. DO NOT EXPOSE SKIN TO
RADIATION WHEN HOT CUTTING OR WELDING.
Other Precautions:PROVIDE PROTECTIVE SCREENS TO SHIELD OTHERS. WHEN
ELECTRODES AND FLUXES ARE CONSUMED, THE FUME AND GAS DECOMPOSITION
PRODUCTS GENERATED ARE DIFFERENT IN FORM FROM THE INGREDIENTS
LISTED. NEW COMPOUNDS NOT IN THE ELECTRODES MAY FORM.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE WELD FUME RESPIRATOR OR AIR SUPPLIED
RESPIRATOR WHEN CUTTING, GRINDING OR WELDING IN A CONFINED SPACE OR
WHERE LOCAL EXHAUST OR GENERAL VENTILATION DOES NOT KEEP EXPOSURE
BELOW RECOMMENDED LIMITS. USE ONLY NIOSH APPROVED RESPIRATORS.
Ventilation:USE ENOUGH VENTILATION WHEN CUTTING, GRINDING OR WELDING TO
KEEP THE DUST, FUMES & GASES FROM THE WORKERS BREATHING ZONE
Other Protective Equipment:FLAME RETARDANT CLOTHING WHEN CUTTING,
GRINDING OR WELDING. DO NOT EXPOSE SKIN TO RADIATION WHEN HOT
CUTTING OR WELDING.
Work Hygienic Practices:WASH THOROUGHLY BEFORE EATING OR SMOKING.
LAUNDER CONTAMINATIED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
WELDING AND HOT CUTTING FUMES & GASES CANNOT BE CLASSIFIED SIMPLY.
THEIR COMPOSITION AND QUANTITY ARE DEPENDENT ON THE METAL BEING
WELDED, THE PROCEDURES, PROCESSES AND THE TYPE OF WIRE OR
ELECTRODESUSED. OTHER INFLUENCING FACTORS ARE THEPRESENCE OF
CONTAMINANTS. CHLORINATED SOLVENTS MAY DECOMPOSE TO TOXIC GASES.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:1125F,607C
Spec Gravity:9.5
Solubility in Water:INSOLUBLE
Appearance and Odor:ROD
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND BASES
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:WELDING/CUTTING OPERATIONS MAY INCLUDE
ELEMENTAL METALS, OXIDES OF THE METALS, FUMES/GASES &
ELECTROMAGNETIC RADIATION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W FEDERAL, STATE & LOCAL REGULATIONS
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: VS387 PANTONE PRO BLUE TOUGH TEX INK 1 LB
Cage: 55269
Proprietary Ind: Y
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 55269
=======================================================
Contractor Summary
=======================================================
Cage: 09177
Cage: 55269
Cage: EO971
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES/SKIN: IRRITATION.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: IRRITATION.
Medical Cond Aggravated By Exposure: PERSONS W/DERMATITIS.
First Aid: EYES: FLUSH W/WATER. SKIN: WASH W/SOAP & WATER. INGESTION: DON'T
INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: WIPE UP. DISPOSE OF WIPES IN APPROVED WASTE
CONTAINERS. IF PETROLEUM HYDROCARBON IS USED, PROVIDE SUFFICIENT VENTILATION.
Waste Disposal Methods: DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
Handling And Storage Precautions: AVOID STORAGE IN HOT AREAS. KEEP CONTAINERS
CLOSED WHEN NOT IN USE. READ & FOLLOW LABEL PRECAUTIONS. DON'T REUSE
CONTAINER.
Other Precautions: FOR COMMERCIAL/INDUSTRIAL USE ONLY. KEEP FROM REACH OF
CHILDREN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: CC
Flash Point Text: 250F
Extinguishing Media: CO2, FOAM, DRY CHEMICAL
Fire Fighting Procedures: USE WATER TO KEEP CONTAINERS COOL. WATER WILL NOT BE
EFFECTIVE IN FIGHTING FIRES.
Unusual Fire/Explosion Hazard: DENSE SMOKE MAY BE GENERATED WHILE BURNING.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT REQUIRED.
Ventilation: GENERAL VENTILATION IS REQUIRED
Other Protective Equipment: NONE REQUIRED
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 500-590F
Vapor Density: >1
Spec Gravity: >1
Evaporation Rate & Reference: SLOWER THAN BU AC
Solubility in Water: INSOLUBLE
Appearance and Odor: COLORED PASTE W/OILY ODOR
Percent Volatiles by Volume: 10-30
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE
Materials To Avoid: NON-REACTIVE MATERIAL
Hazardous Decomposition Products: BY FIRE: SMOKE
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: VS387 PANTONE PRO BLUE TOUGH TEX INK 1 LB
Cage: 55269
Company Name: VAN SON HOLLAND INK CORP
Street: 92 UNION STREET
Zipcode: 11501-3428
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: EYES/SKIN: IRRITATION.
IRRITATION.
=======================================================
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:850J CHROMA ONE & CHROMA ONE
Preparer's Name:T R LOUER
CAGE:23027
CAGE:90227
CAGE:23027
============= Composition/Information on Ingredients =============
Ingred Name:FATTY ACIDS, LINSEED OIL, REACTION PRODUCTS POLYMER;
ACRYLIC POLYMER *96-2*
CAS:96591-17-2
Ingred Name:BUTYL ACETATE (N-BUTYL ACETATE) *96-2*
CAS:123-86-4
RTECS #:AF7350000
Other REC Limits:150 PPM
OSHA PEL:710 MG/CUM
ACGIH TLV:713 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:DIKETOPYRROLOPYRROL RED PIGMENT
Ingred Name:AMYL ACETATE
CAS:628-63-7
RTECS #:AJ1925000
Other REC Limits:530 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *96-2*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 38%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOLATILE ORGANIC CONTENT: 4.4 LBS/GAL
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE NOSE & THROAT
IRRITATION. EXPOSURE TO ISOCYANATES MAY CAUSE RESPIRATORY
SENSITIZATION & MAY CAUSE A DECREASE IN LUNG FUNCTION WHICH MAY BE
PERMANENT. EYES: IRRITATION/BURNING. SK IN: IRRITATION &
DERMATITIS. REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE
PERMANENT BRAIN & CNS DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:GI DISTRESS, IRRITATION, EYE WATERING,
HEADACHES, NAUSEA, DIZZINESS, LOSS OF COORDINATION, BURNING,
DISCOMFORT.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH W/PLENTY OF
WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:<100F
Lower Limits:0.8
Upper Limits:23
Extinguishing Media:WATER SPRAY, FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIPMENT & SCBA. WATER
FROM FOG NOZZLES MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:WHEN HEATED > THE FLASH POINT, EMITS
FLAMMABLE VAPORS, WHEN MIXED W/AIR CAN BURN/BE EXPLOSIVE. FINE
MISTS/SPRAYS MAY BE FLAMMABLE AT TEMPS < THE FLASH POINT.
================== Accidental Release Measures ==================
Spill Release Procedures:DON'T BREATHE VAPORS. DON'T GET IN EYES/ON
SKIN. WEAR A POSITIVE PRESSURE SUPPLIED AIR VAPOR/PARTICULATE
RESPIRATOR(NIOSH/MSHA TC-19C)& PROTECTIVE MATERIAL. REMOVE SOURCES
OF IGNITION. ABSORB W/INERT MATERIAL. VENTILATE AREA. (SEE SUPP)
Neutralizing Agent:DECONTAMINATION SOLUTIONS: 20% SURFACTANT (TERGITOL
TMN 10), 80% WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & FLAME.
CLOSE CONTAINER AFTER EACH USE. GROUND CONTAINERS WHEN POURING.
DON'T STORE >120F. OBSERVE LABEL PRECAUTIONS.
Other Precautions:DON'T SAND, FLAME CUT, BRAZE/WELD DRY COATING W/O A
NIOSH/MSHA APPROVED RESPIRATOR/APPROPRIATE VENTILATION. DON'T
BREATHE VAPORS. DON'T PERMIT ANYONE W/O PROTECTION IN THE PAINTING
AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A POSITIVE PRESSURE SUPPLIED AIR
RESPIRATOR(NIOSH/MSHAT TC-19C)DURING APPLICATION. INDIVIDUALS W/A
HISTORY OF LUNG/BREATHING PROBLEMS/REACTION TO ISOCYANATES
SHOULDN'T USE/BE EXPOSED TO PRODUCT.
Ventilation:SUFFICIENT IN VOLUME & PATTERN TO KEEP CONTAMINANTS BELOW
APPLICABLE OSHA LIMITS.
Other Protective Equipment:COVERALLS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE
EATING/SMOKING.
Supplemental Safety and Health
VOLATILE BY VOLUME: 31.8-86.3%. SPILLS: POUR LIQUID DECONTAMINATION
SOLUTION OVER THE AREA & ALLOW TO SIT 10 MINS, MINIMUM. THIS
PROCEDURE CAN GENERATE PRESSURE. DON'T SEAL CONTAINERS. AFTER 48
HOURS, SEAL CONTAINER & DISPOSE OF MATERIAL.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:169-415F
Vapor Density:>1
Evaporation Rate & Reference:LESS THAN AIR
Solubility in Water:MISCIBLE
Percent Volatiles by Volume:(SUPP)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:HEAT, SPARKS, FLAME, TEMPS >120F.
Hazardous Decomposition Products:CO, CO2, SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE/DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T ALLOW MATERIAL TO CONTAMINATE GROUND WATER
SYSTEMS. DON'T INCINERATE IN CLOSED CONTAINERS. FLAMMABLE LIQUID
UN1263.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SCS 1209
Kit Part:Y
Preparer's Name:DA POLSINELLI
CAGE:OD426
CAGE:OD426
============= Composition/Information on Ingredients =============
Ingred Name:METHYLTRIACETOXYSILANE
CAS:4253-34-3
RTECS #:VV4500000
Fraction by Wt: 1-5%
OSHA PEL:10 PPM
ACGIH TLV:10 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:METHYLTRIACETOXYSILANE LD50 ORAL
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Effects of Overexposure:UNCURED PRODUCT CONTACT WILL IRRITATE LIPS,
GUMS, TONGUE AND SKIN.INHALATION APPLIES ONLY IN
UNCURED STATE. MAY CAUSE MILD RESPIRATORY IRRITATION.UNCURED
PRODUCT CONTACT IRRITATES EYES.
Medical Cond Aggravated by Exposure:RESPIRATORY, DERMAL AILMENTS,
APPLIES IN UNCUREDSTATE, ACETIC ACID RELEASED DURING CURING.
======================= First Aid Measures =======================
First Aid:EYE: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR 15 MINUTES
GET MEDICAL ATTENTIONSKIN: REMOVE COMPLETELY WITH A DRY CLOTH OR
PAPER TOWEL, BEFORE WASHING WITHDETERGENT AND WATER GET MEDICAL
ATTENTIO N IF IRRITATION PERSISTS; INHAL: REMOVETO FRESH AIR;
INGST: DO NOT INDUCE VOMITING. SLOWLY DILUTE W/1-2 GLASSES OF WTR
OR MILK & SEEK MEDICAL ATTENTION.NEVER GIVE ANYTHING TO AN
UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:>400F/>204C
Extinguishing Media:ALL STANDARD FIREFIGHTING MEDIA
Fire Fighting Procedures:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE, SCRAPE OR SOAK UP IN AN INERT MATERIAL &
PUTIN A CONTAINER FOR DISPOSAL. WARN OTHER WORKERS OFSPILL. WEAR
PROTECTIVE EQUIPMENT.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH SKIN/EYES. REMOVE
CONTACT LENS BEFORE USING SEALANT. DO NOT HANDLE LENSES UNTIL ALL
SEALANT HAS BEEN CLEANED FROM FINGERTIPS,NAILS
Other Precautions:RESIDUAL SEALANT MAY REMAIN ON FINGERS FOR SEVERAL
DAYS AND TRANSFER TO LENSES AND CAUSE SEVERE EYE IRRITATION.
PRODUCT RELEASES ACETIC ACID DURING APPLICATIONAND CURING. USE IN
WELL VENTILATED AREA TO PREVENT IRRITATION BY VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE IN A WELL VENTILATED AREA TO PREVENT
IRRITATION BY VAPORS.
Ventilation:EXHAUST VENTILATION. LOCALIZED VENTILATION SHOULD BE USED
TOCONTROL DUST LEVELS AND KEEP ACETIC ACID BELOW TLV OF 10 PPM
Other Protective Equipment:NONE
Supplemental Safety and Health
AVOID CONTACT WITH SKIN AND EYES: REMOVE CONTACT LENSES BEFORE USING
SEALANT. DONOT HANDLE LENSES UNTIL ALL SEALANT HAS BEEN CLEANED
FROM THE FINGERTIPS, NAILS,AND CUTICLES. RESIDUAL SEALANT MAY REMA
IN ON FINGERS FOR SEVERAL DAYS AND TRANSFER TO LENSES AND CAUSE
SEVERE EYE IRRITATION.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NA
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:NEG
Vapor Density:NEG
Spec Gravity:1.07
Evaporation Rate & Reference:<1
Solubility in Water:INSOLUBLE
Appearance and Odor:PASTE ALUMINUM COLOR WITH ACETIC ACID ODOR
Percent Volatiles by Volume:<5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:SILICON DIOXIDE AND ACETIC ACID
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH
FEDERALSTATE, AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
NIIN: 00-174-9672
Product ID: DESCALER
Cage: 75656
Box: 1987
=======================================================
Item Description Information
=======================================================
Item Manager: S9G
Item Name: CORROSION REMOVING COMPOUND
Unit of Issue: GL
UI Container Qty: 6
=======================================================
Ingredients
=======================================================
Cas: 7664-38-2
RTECS #: TB6300000
Percent by Wt: 42.7
OSHA PEL: 1 MG/M3
ACGIH TLV: 1 MG/M3
ACGIH STEL: 3 MG/M3
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 7732-18-5
RTECS #: ZC0110000
Percent by Wt: 45.78
------------------------------
Percent by Wt: 11.52
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: HEALTH HAZARDS ACUTE AND CHRONIC: NONE
Signs And Symptions Of Overexposure: DIZZINESS.
Medical Cond Aggravated By Exposure: NONE KNOWN.
First Aid: INHALATION: BREATH FRESH AIR. DIRECT EYE CONTACT: RINSE WITH COLD
WATER. CALL A DOCTOR. SKIN: RINSE WITH COLD WATER.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: DILUTE WITH WATER & REGULAR SEWAGE DISPOSAL.
Waste Disposal Methods: PLEASE DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL,
STATE, AND MUNICIPAL LAWS.
Handling And Storage Precautions: AVOID OPEN FLAMES.
Other Precautions: AVOID EXCESSIVE INHALATION, DIRECT CONTACT WITH EYES.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TOC
Flash Point: >100.C, 212.F
Lower Limits: NO DATA
Upper Limits: NO DATA
Extinguishing Media: WATER FOG
Fire Fighting Procedures: NONE
Unusual Fire/Explosion Hazard: NO SPECIAL FIRE HAZARDS WITH THIS PRODUCT.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE IN A WELL-VENTILATED AREA.
Ventilation: GENERAL VENTILATION
Other Protective Equipment: MINIMUM (SAME AS PHOSPHRIC ACID)
=======================================================
Physical/Chemical Properties
=======================================================
HCC: C1
B.P. Text: UNKNOWN
M.P/F.P Text: UNKNOWN
Decomp Text: UNKNOWN
Vapor Pres: UNKNOWN
Vapor Density: NOT TESTED
Spec Gravity: 1.25
PH: <2.0
Viscosity: UNKNOWN
Solubility in Water: COMPLETE
Appearance and Odor: WATER WHITE LIQUID
Corrosion Rate: UNKNOWN
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: MATERIAL IS VERY STABLE
Materials To Avoid: UNKNOWN
Hazardous Decomposition Products: MAY FORM CARBON DIOXIDE,CARBON MONOXIDE AND
VARIOUS HYDROCARBONS
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT KNOWN
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
Transport Information: CORROSIVE LIQUID, ACIDIC, INORGANIC, NOS, UN3264.
CONTAINS PHOSPHORIC ACID.
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 146852
Product ID: DESCALER
Review Date: 08/01/1999
Tech Entry NOS Shipping Nm: CONTAINS PHOSPHORIC ACID (42.7%)
Net Unit Weight: 10.42 LBS/G
Multiple KIT Number: 0
Unit Of Issue: GL
Container QTY: 6
Additional Data: PSN PER MSDS DATED APRIL 28, 1998.
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: DWF
Symbols: G
DOT Proper Shipping Name: CORROSIVE LIQUID, ACIDIC, INORGANIC, N.O.S.
Hazard Class: 8
UN ID Num: UN3264
DOT Packaging Group: III
Label: CORROSIVE
Special Provision: T7
Packaging Exception: 154
Non Bulk Pack: 203
Bulk Pack: 241
Max Qty Pass: 5 L
Max Qty Cargo: 60 L
Vessel Stow Req: A
Water/Ship/Other Req: 40
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ESE
IMO Proper Shipping Name: CORROSIVE LIQUID, ACIDIC, INORGANIC, N.O.S. o
IMDG Page Number: 8147-1
UN Number: 3264
UN Hazard Class: 8
IMO Packaging Group: I/II/III
Subsidiary Risk Label: -
EMS Number: 8-15
MED First Aid Guide NUM: 760
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: HLF
IATA UN ID Num: 3264
IATA Proper Shipping Name: CORROSIVE LIQUID, ACIDIC, INORGANIC, N.O.S. *
IATA UN Class: 8
IATA Label: CORROSIVE
UN Packing Group: III
Packing Note Passenger: 818
Max Quant Pass: 5L
Max Quant Cargo: 60L
Packaging Note Cargo: 820
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: HKA
AFI Symbols: *
AFI Proper Shipping Name: CORROSIVE LIQUID, ACIDIC, INORGANIC, N.O.S.
AFI Hazard Class: 8
AFI UN ID NUM: UN3264
AFI Packing Group: III
Special Provisions: P5
Back Pack Reference: A12.3
=======================================================
HAZCOM Label
=======================================================
Product ID: DESCALER
Cage: 75656
Company Name: LOS ANGELES CHEMICAL CO
Street: 4545 ARDINE ST
PO Box: 1987
Zipcode: 90280
Label Required IND: Y
Date Of Label Review: 08/01/1999
Status Code: A
Origination Code: F
Signal Word: WARNING
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: TARGET ORGANS:N/P. HEALTH HAZARDS ACUTE AND CHRONIC:
NONE
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DUCT WRAP
Preparer's Name:MARK SULLIVAN
CAGE:25143
CAGE:25143
============= Composition/Information on Ingredients =============
Ingred Name:GLASS, FIBROUS
RTECS #:LK3651000
Fraction by Wt: 83-97%
Other REC Limits:3000000 FB/CUM
OSHA PEL:15 MG/M3 (DUST)
ACGIH TLV:10 MG/M3 (DUST);9192
Ingred Name:UREA EXTENDED PHENOL FORMALDEHYDE RESIN CURED
CAS:25104-55-6
Fraction by Wt: 3-17%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: ITCHING AND IRRITATION OF
THE UPPER RESPIRATORY TRACT. SKIN: DERMATITIS, SENSITIZATION,
MECHANICAL IRRITANT. EYES: MECHANICAL IRRITANT. INGESTION: MAY
CAUSE DISCOMFORT OR IRRITATION OF THE GI TRACT.
Explanation of Carcinogenicity:FIBER GLASS WOOL IS POSSIBLE HUMAN
CARCINOGEN. RESPIRABLE DUST FROM THIS PRODUCT IS CLASSIFIED IN
GROUP 2B.
Effects of Overexposure:INHALATION: ITCHING & IRRITATION OF THE UPPER
RESPIRATORY TRACT. SKIN: DERMATITIS, SENSITIZATION, MECHANICAL
IRRITANT. EYES: MECHANICAL IRRITANT. INGESTION: MAY CAUSE
DISCOMFORT OR IRRITATION OF THE G I TRACT.
Medical Cond Aggravated by Exposure:UPPER RESPIRATORY & LUNG DISEASES
MAY BE AGGRAVATED BY DUST.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/FLOWING WATER FOR AT LEAST 15 MINUTES. SKIN:
FREQUENT RINSING W/WATER TO REMOVE ACCUMULATED FIBERS. TREAT AS
MECHANICAL IRRITANT. INHALATION: REMOVE TO FRESH AIR. DRINK WATER
TO CLEAR TH ROAT & BLOW NOSE TO EVACUATE FIBERS. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE WATER, FOAM, DRY CHEMICAL OR CO2
Fire Fighting Procedures:WEAR SCBA AND PROTECTIVE CLOTHING. DENSE SMOKE
MAY LIMIT VISABILITY IN ENCLOSED AREAS.
Unusual Fire/Explosion Hazard:RESIN/PAPER OR PLASTIC FACINGS WILL BURN
CAUSING DENSE ACRID SMOKE. VINYL FACED PRODUCTS IN FIRE CONDITIONS
GIVE OFF HYDROGEN CHLORIDE, A HIGHLY IRRITATING GAS.
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP & DISCARD LARGE PIECES. VACUUM CLEAN
DUST. USE A DUST SUPPRESSENT IF SWEEPING IS NECESSARY.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP MATERIAL DRY & MINIMIZE THE
GENERATION OF DUST.
Other Precautions:DURING INITIAL HEAT-UP OF HIGH TEMPERATURE INSULATION
PRODUCTS TO TEMPERATURES >350F, AN ACRID ODOR OR SMOKE MAY BE GIVEN
OFF. IN CONFINED SPACES, OCCUPANTS SHOULD WEAR SCBA DURING THIS
PERIOD.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A DISPOSABLE MASK DESIGNED FOR NUISANCE
TYPE DUSTS SUCH AS 3M MODEL 9900 OR ITS EQUIVALENT.
Ventilation:IF SUFFICIENT NATURAL VENTILATION ISN'T AVAILABLE, USE
MECHANICAL VENTILATION TO ASSURE EXPOSURES TO AIRBORNE DUSTS <TLV
Other Protective Equipment:WEAR LONG-SLEEVED, LOOSE FITTING CLOTHING &
HEAD COVERING
Work Hygienic Practices:WASH WORK CLOTHES SEPARATELY FROM OTHER
CLOTHING TO PREVENT GLASS FIBER MIGRATION. RINSE WASHER THOROUGHLY.
Supplemental Safety and Health
SOME PRODUCTS HAVE VINYL, KRAFT PAPER, FOIL OR GLASS CLOTH FACING.
================== Physical/Chemical Properties ==================
Spec Gravity:VARIABLE
Solubility in Water:INSOLUBLE
Appearance and Odor:YELLOW OR BLACK FIBROUS PRODUCT, NO APPRECIABLE
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HYDROFLUORIC ACID WILL DISOLVE GLASS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CO, CO2, HYDROCARBON PARTICULATE,
CARBON PARTICULATE, HYDROGEN CYANIDE, HYDROGEN CHLORIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS MATERIAL IS NOT REGULATED UNDER "RCRA"
HAZARDOUS WASTE REGULATIONS. MAY BE DISPOSED IN LANDFILL. COMPLY
W/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:COMMON SALT
Preparer's Name:GLEN WARNER
CAGE:3K279
CAGE:3K279
============= Composition/Information on Ingredients =============
Ingred Name:NONHAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: OVEREXPOSURE CAUSES READILY
REVERSIBLE CHANGES WHICH DISAPPEAR AFTER END OF EXPOSURE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:EYE: WASH WITH WATER FOR AT LEAST 15 MINUTES. SKIN: FLUSH
WITH COPIOUS AMOUNTS OF WATER. CALL MD . INHAL:REMOVE TO FRESH AIR.
SUPPORT BRTHG (GIVE O*2/ARTF RESP) . INGEST: CALL MD IMMED (FP N).
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:0
Upper Limits:0
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP UP WITH SHOVEL/HOSE DOWN WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:2575F,1413C
Vapor Pres:0.0231@20C
Spec Gravity:2.164
Evaporation Rate & Reference:0
Solubility in Water:100%
Appearance and Odor:CRYSTALLINE WITH NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:EXCEEDINGLY HIGH TEMPERATURES.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DUMPING SOLID/IRRIGATION W/WATER. DISPOSE OF
I/A/W FEDERAL, STATE AND LOCAL REGS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ACETONITRILE 00170, A9964LOT008
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:ACETONITRILE LD50: (ORAL, RAT) 2730 MG/KG
CAS:75-05-8
RTECS #:AL7700000
= Wt:99.
OSHA PEL:70 MG/M3;40 PPM
ACGIH TLV:67 MG/M3;40 PPM
ACGIH STEL:101 MG/M3;60 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: MAY CAUSE MODERATE EYE IRRIT.
VAPS MAY CAUSE EYE IRRIT. SKIN: MAY BE HARMFUL IF ABSORBED THRU
SKIN. MAY BE METABOLIZED TO CYANIDE WHICH IN TURN ACTS BY
INHIBITING CYTOCHROME OXIDASE IMPAIRING CEL LULAR RESPIRATION.
INGEST: MAY CAUSE IRRIT OF DIGESTIVE TRACT. MAY CAUSE EFTS SIMILAR
TO THOSE FOR INHAL EXPOS. INHAL: HARMFUL IF INHALED. INHAL OF HIGH
CONCS MAY CAUSE CNS EFTS CHARACTERIZED BY HDCH, DIZZ, UNCON &
COMA. MAY CAUSE LIVER & KIDNEY DMG. VAPS MAY CAUSE DIZZ OR
SUFFOCATION. MAY CAUSE NAUS, DIZZ & HDCH. INHAL MAY LEAD TO DIZZ,
WEAK & DROW, LEADING TO STUPOR, UNCON & EVEN DEATH. INHAL MA Y LEAD
TO(EFTS OF OVEREXP)
Effects of Overexposure:HLTH HAZ: HEMATEMESIS, CONVULSIONS, CHOCK, COMA
& POSSIBLE DEATH. CHRONIC: CHRONIC INHAL & INGEST MAY CAUSE EFTS
SIMILAR TO THOSE OF ACUTE INHAL & INGEST. MAY BE METABOLIZED TO
CYANIDE WHICH IN TURN A CTS BY INHIBITING CYTOCHROME OXIDASE
IMPAIRING CELLULAR RESPIRATION. ANIMAL STUDIES HAVE REPORTED THAT
FETAL EFTS/ABNORMALITIES MAY OCCUR WHEN MATERNAL TOXICITY IS SEEN.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN, OCCASNLY
LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. SKIN: GET MED AID
IMMED. FLUSH SKIN W/PLENTY OF SOAP & WATER FOR AT LEAST 15 MIN
WHILE REMOV ING CONTAM CLTHG & SHOES. INGEST: IF VICTIM CONSCIOUS &
ALERT, GIVE 2-4 CUPFULS OF MILK OR WATER. NEVER GIVE ANYTHING BY
MOUTH TO UNCON PERSON. GET MED AID IMMED. INHAL: GET MED AID
IMMED. REMOVE FRO M EXPOS TO FRESH AIR IMMED. IF BRTHG IS DFCLT,
GIVE OXYG. NOTES TO MD: EXPOS SHOULD BE TREATED AS CYANIDE
POISONING. EFTS MAY BE DELAYED. ANTIDOTE: ALWAYS HAVE CYANIDE
ANTIDOTE KIT ON HAND WHEN WORING W/CYANIDE CMPDS. GET MED ADVICE
TO USE.
===================== Fire Fighting Measures =====================
Flash Point:=6.C, 42.8F
Autoignition Temp:=524.C, 975.2F
Lower Limits:4.4%
Upper Limits:16.0%
Extinguishing Media:SM FIRES:USE DRY CHEM, CO*2, WATER
SPRAY/ALCOHOL-RESIST FOAM. USE WATER SPRAY TO COOL FIRE-EXPOS
CNTNRS. WATER MAY BE INEFFECTIVE. DO NOT USE STRAIGHT STREAMS OF
WATER. LG (SUPDAT)
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . NFPA RATING: HEALTH-2; FLAMMABILITY-3; REACTIVITY-0.
Unusual Fire/Explosion Hazard:CNTNRS CAN BUILD UP PRESS IF EXPOS TO
HEAT &/OR FIRE. VAPS MAY FORM EXPLO MIX W/AIR. VAPS CAN TRAVEL TO
IGNIT SOURCE & FLASH BACK. COMBUST GENERATES TOX FUMES. USE WATER
SPRAY TO KEEP FIRE-EXPOS CNTNR S COOL. FLAM LIQ. VAPS MAY BE
HVR/AIR. THEY CAN SPREAD ALONG GROUND & COLLECT IN LOW/CONFINED
AREAS. CNTNRS MAY (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTIVE EQUIPMENT.
AVOID RUNOFF INTO STORM SEWERS AND DITCHES WHICH LEAD TO WATERWAYS.
REMOVE ALL SOURCES OF IGNITION. ABSORB SPILL USING AN ABSORBENT,
NON-COMBUSTIBLE MATERIAL SUCH AS EARTH, SAND OR VERMICULITE. A
VAPOR SUPPRESSING FOAM MAY BE USED TO REDUCE VAPORS. WATER SPRAY
MAY REDUCE VAPOR BUT MAY NOT PREVENT IGNITION IN CLOSED SPACES.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPKS & FLAME.
KEEP AWAY FROM SOURCES OF IGNIT. STORE IN TIGHTLY CLOSED CNTNR.
KEEP FROM CNTCT W/OXIDIZING MATLS. STORE IN COOL, DRY, WELL-VENTD
AREA AWAY FROM INCOMPAT SUBSTANCES. WASH THOROUGHLY AFTER HNDLG.
REMOVE CONTAM CLTHG & WASH BEFORE USE. USE ONLY IN WELL VENTD AREA.
Other Precautions:GROUND & BOND CNTNRS WHEN TRANSFERRING MATL. AVOID
CNTCT W/EYES, SKIN & CLTHG. EMPTY CNTNRS RETAIN PROD RESIDUE (LIQ
&/OR VAP) & CAN BE DANGEROUS. KEEP CNTNR TIGHTLY CLSD. AVOID CNTCT
W/HEAT, SPKS & F LAME. DO NOT INGEST/INHALE. DO NOT PRESSURIZE,
CUT, WELD, BRAZE, SOLDER, DRILL, GRIND/EXPOSE EMPTY C NTNRS TO
(SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
29 CFR 1910.134 OR EUROPEAN STANDARD EN 149. ALWAYS USE A NIOSH OR
EUROPEAN STANDARD EN 149 APPROVED RESPIRATOR WHEN NECESSARY.
Ventilation:USE ADEQ GEN/LOC EXHST VENT TO KEEP AIRBORNE CONCS BELOW
PEL. ACETONITRILE: EXPOS LIMS: ACGIH-40PPM; 67 MG/M3; 60PPM STEL;
101 MG/M3 STEL. NIOSH-20PPM (SUPDAT)
Other Protective Equipment:ANSI APPROVED EYE WASH AND DELUGE SHOWER .
WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN EXPOSURE.
Supplemental Safety and Health
OTHER PRECS:HEAT, SPKS/OPEN FLAME. EXTING MEDIA:FIRES:USE DRY CHEM,
CO*2, ALCOHOL-RESIST FOAM/WATER SPRAY. COOL CNTNRS W/FLOODING QTYS
OF WATER UNTIL WELL AFTER FIRE IS OUT. EXPLO HAZ:MAY EXPLODE WHEN
HEATED. VENT:TWA; 34MG/M3 TWA; 500PPM IDLH. OSHA-40PPM TWA; 70
MG/M3 TWA. OSHA VACATED PELS:40PPM TWA; 70MG/M3 TWA.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:=-50.C, -58.F
Decomp Temp:Decomp Text:NOT AVAILABLE
Vapor Pres:73 MM HG
Vapor Density:1.4(AIR=1)
Spec Gravity:0.7810
pH:NOT AVAILABLE
Viscosity:0.36 CP 20 DEG
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID; SWEETISH ODOR - AROMATIC
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CHLORINE FLUORIDE, FLUORINE, 2-CYANO-2-PROPYL NITRATE, DINITROGEN
TETRAOXIDE, INDIUM, DIPHENYL SULFOXIDE, TRICHLOROSILANE, N-FLUORO
CMPDS, IRON (III) PERCHLORATE, LANTHANIDE, NITRIC ACID, PERCHLORIC
ACID, SULFURIC ACID, SUL
Stability Condition to Avoid:STABLE UNDER NORMAL TEMPERATURES AND
PRESSURES. AVOID INCOMPATIBLE MATERIALS, IGNITION SOURCES.
Hazardous Decomposition Products:HYDROGEN CYANIDE, NITROGEN OXIDES,
CARBON MONOXIDE, CARBON DIOXIDE.
=================== Toxicological Information===================
Toxicological Information:CAS #75-05-8, RTECS #AL7700000. LD50/LC50 -
INHAL, MOUSE: LC50=2693 PPM/1H; INHAL, RABBIT: LC50=2828 PPM/4H;
INHAL, RAT: LC50=7551 PPM/8H; ORAL, MOUSE: LD50=269 MG/KG; ORAL,
RABBIT: LD50=50 MG/KG; ORA L, RAT: LD50=2730 MG/KG; SKIN,
RABBIT:LD50=1250 MG/KG; CARCINOGENICITY - ACGIH: A4 - NOT
CLASSIFIABLE AS HUMAN CARCIN. EPIDEMIOLOGY - NO INFO AVAIL.
TETRAGENICITY - EMBRYO OR FETUS: STUNTED FETUS, IHL -HAMSTER
TCLO=8000 PPM/1H. SPECIFIC DEVELOPMENTAL ABNORMS: MUSCULOSKELETAL,
ORL-HAMSTER TCLO=300 MG/KG. REPRO EFTS - FERTILITY:
POST-IMPLANTATION MORTALITY, ORL-HAMSTER TDLO=400 MG/KG &
IHL-HAMSTER TC LO=5000 PPM/1H. (OTHER INFO)
===================== Ecological Information =====================
Ecological:EXOTOXICITY: FATHEAD MINNOW (HARD WATER) TLM=1150 PPM/24H.
ENVIRONMENTAL FATE: NO INFO REPORTED. PHYSICAL/CHEMICAL: NO INFO
AVAIL. OTHER: NONE. OTHER INFO: ADVICE IMMED (SHOW LABEL WHERE
POSS). WGK (W ATER DANGER/PROT) CAS #75-05-8: 2. CANADA: CAS
#75-05-8 IS LISTED ON CANADA'S DSL/NDSL LIST, HAS A WHMIS
CLASSIFICATION OF B2, D1B, D2B. IT IS NOT LISTED ON CANADA'S INGRED
DISCLOSURE LIST. EXPOS LIMS : CAS #75-05-8: OEL-ARAB REPUBLIC OF
EGYPT:TWA 40 PPM (70 MG/M3); SKIN OEL-AUSTRALIA: TWA 40 PPM (70
MG/M3); STEL 60 PPM; SKIN OEL-AUSTRIA; TWA 40 PPM (70 MG/M3)
OEL-BELGIUM:TWA 40 PPM (67 MG/M3); STE L 60 PPM (10 MG/M3);
(TRANSPORT INFO)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE AND LOCAL REGULATIONS. RCRA D-SERIES MAXIMUM CONCENTRATION OF
CONTAMINANTS: NONE LISTED. RCRA D-SERIES CHRONIC TOXICITY REFERENCE
LEVELS: NONE LIS TED. RCRA F-SERIES: NONE LISTED. RCRA P-SERIES:
NONE LISTED. RCRA U-SERIES: CAS #75-05-8: WASTE #U00 3 (IGNITABLE
WASTE; TOXIC WASTE).
=================== MSDS Transport Information ===================
Transport Information:SHIPPING NAME - US DOT: ACETONITRILE; IATA: NO
INFO AVAIL; RID/ADR: NO INFO AVAIL. IMO: NO INFO AVAIL.
ACETONITRILE. HAZ CLASS - US DOT: 3; IMO: 3(6.1). UN NUMBER: US
DOT: UN1648; IMO: UN1648. PACKING GROUP: US DOT: II; IMO: II.
ADDNL INFO: IMO: FLASHPOINT 6C. ECOLOGICAL INFO: SKIN
OEL-DENMARK:TWA 40 PPM (70 MG/M3); STEL 60 PPM (10 MG/M3);
OEL-FINLAND: TWA 40 PPM (70 MG/M3); STEL 60 PPM (10 MG/M3) ;
OEL-FRANCE: TWA 50 MG/M3; STEL 100 MG/M3; SKIN JAN9 OEL-THE
NETHERLANDS: TWA 40 PPM (70 MG/M3) OEL-THE PHILIPPINES: TWA 40 PPM
(70 MG/M3) OEL-RUSSIA: STEL 10 MG/M3; OEL-SWITZERLAND: TWA 40 PPM
(70 M G/M3); STEL 80 PPM; (STATE REG INFO)
===================== Regulatory Information =====================
SARA Title III Information:CAS #75-05-8: SARA SECTION 302(RQ): FINAL
RQ=5000 LBS (2270 KG). SECTION 302(TPQ): NONE OF CHEMICALS IN
PRODUCT HAVE TPQ. SARA CODES: ACUTE, CHRONIC, FLAMMABLE. SECTION
313: MATERIAL CONTAINS ACETONIT RILE (CAS #75-05-8, 99%) WHICH IS
SUBJECT TO REPORTING REQS OF SECTION 313 OF SARA TITLE III & 40 CFR
PART 373.
Federal Regulatory Information:CAS #75-05-8: TSCA: LISTED ON TSCA
INVENTORY. HLTH & SFTY REPORTING LIST: EFTIVE DATE: OCT 4, 1982;
SUNSET DATE: OCT 4, 1992. CHEM TEST RULES: NONE OF CHEMS IN PROD
UNDER CHEM TEST RULE. SECTION 12B:NONE OF CHEMS LISTED UNDER TSCA
SECTION 12B. TSCA SIGNIFICANT NEW USE RULE: NONE OF CHEMS IN MATL
HAVE SNUR UNDER TSCA. CLEAN AIR ACT: LISTED AS HAZ AIR POLLUTANT
(HAP). MATL DOES NOT CNTN ANY CLASS 1 OR CLASS 2 OZONE DEPLETORS.
CLEAN WATER ACT: NONE OF CHEMS IN PROD LISTED AS HAZ SUBSTANCES
UNDER C WA. NONE OF CHEMS LISTED AS PRIORITY OR TOX POLLUTANTS
UNDER CWA. NONE CONSIDERED HIGHLY HAZ BY OSHA.
EUROPEAN/INTERNATIONAL (OTHER INFO)
State Regulatory Information:CAS #75-05-8 CAN BE FOUND ON FOLLOWING
STATE RIGHT TO KNOW LISTS: CALIFORNIA, NEW JERSEY, FLORIDA,
PENNSYLVANIA, MINNESOTA, MASSACHUSETTS. CALIFORNIA NO SIGNIFICANT
RISK LEVEL: NONE OF CHEMS IN THIS P ROD ARE LISTED. TRANSPORT INFO:
SKIN OEL-TURKEY: TWA 40 PPM (70 MG/M3) OEL-UNITED KINGDOM:TWA 40
PPM (70 MG/M3); STEL 60 PPM; OEL IN BULGARIA, COLOMBIA, JORDAN,
KOREA CHECK ACGIH. TLV OEL IN NEW ZEALA ND, SINGAPORE, VIETNAM
CHECK ACGIH TLV.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:RU 2000 REGULAR UNLEADED GASOLINE
Preparer's Name:J. C. WILLETT
CAGE:54527
CAGE:54527
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 0-25%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS) (SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 0-25%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BENZENE (SARA III)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: 0-5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1PPM/5STEL;1910.1028
ACGIH TLV:10 PPM; A2; 9192
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:HEXANE (N-HEXANE)
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: 0-3%
Other REC Limits:NONE SPECIFIED
OSHA PEL:500 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:METHYL TERT-BUTYL ETHER (SARA III)
CAS:1634-04-4
RTECS #:KN5250000
Fraction by Wt: 0-11%
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ALKANES, CYCLOALKANES, ALKANES & AROMATIC HYDROCARBONS.
CAS:68475-59-2
Fraction by Wt: BALANCE
Other REC Limits:NONE RECOMMENDED
Ingred Name:CYCLOHEXANE (SARA III)
CAS:110-82-7
RTECS #:GU6300000
Fraction by Wt: 0-1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:300 PPM
ACGIH TLV:300 PPM, 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE (SARA III)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 0-3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM/125 STEL
ACGIH TLV:100 PPM/125STEL 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:NAPHTHALENE (SARA III)
CAS:91-20-3
RTECS #:QJ0525000
Fraction by Wt: 0-1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 PPM/15 STEL
ACGIH TLV:10 PPM/15 STEL; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:ALKANES, CYCLOALKANES, ALKENES AND AROMATIC HYDROCARBONS
Fraction by Wt: BALANCE
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS >5 GM/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:EYE-IRRITATING. SKIN-PROLONGED OR
REPEATED CONTACT CAN CAUSE DEFATTING & DRYING, RESULTING IN SKIN
IRRITATION & DERMATITIS. INHALE-IRRITATION TO THE NOSE, THROAT &
RESPIRATORY TRACT & MAY PRODUCE LIVE R & KIDNEY DAMAGE. INGEST-MAY
BE HARMFUL/FATAL IF SWALLOWED, RESULTING IN VOMITING OR ASPIRATION
PNEUMONITIS.
Explanation of Carcinogenicity:BENZENE IS SUSPECTED OF CARCINOGENIC
(LUKEMIA) POTENTIAL IN MAN AND IS LISTED BY IARC, NTP AND OSHA.
Effects of Overexposure:GIDDINESS, HEADACHE, DIZZINESS AND NAUSEA; IN
EXTREME CASES, UNCONCIOUSNESS AND DEATH MAY OCCUR. ASPIRATION
PNEUMONITIS CAN SHOW AS COUGHING, LABORED BREATHING AND CYANOSIS.
OTHER SIGN ARE CHANGES IN URINE OUTPUT, APPEARANCE OR EDEMA,
LOSSOF APPETITE, JAUNDICE AND PAIN IN THE UPPER ABDOMEN ON THE
RIGHT SIDE.
Medical Cond Aggravated by Exposure:PREEXISTING EYE, SKIN AND
RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS
PRODUCT. IMPAIRED LIVER AND KIDNEY FUNCTIONS FROM PREEXISTING
DISORDERS MAY BE AGGRAVATED BY EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYE-FLUSH WITH WATER FOR 15 MINUTES. GET MEDICAL ATTENTION.
SKIN-FLUSH WITH WATER, REMOVE SOILED CLOTHES/SHOES. WASH WITH SOAP
& WATER. INHALE-REMOVE TO FRESH AIR & PROVIDE OXYGEN IF HARD TO
BREATH. G IVE CPR IF NOT BREATHING. GET MEDICAL ATTENTION.
INGEST-DO NOT INDUCE VOMITING. IF VOMITING OCCURS SPONTANEOUSLY
KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION OF LIQUID INTO LUNGS.
GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-40F,-40C
Autoignition Temp:Autoignition Temp Text:UNK
Lower Limits:1.0
Upper Limits:7.8
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, DRY CHEMICAL.
DO NOT USE WATER DIRECTLY, PRODUCT WILL FLOAT & REIGNITE ON
SURFACE.
Fire Fighting Procedures:DO NOT ENTER CONFINED FIRE SPACE WITHOUT FULL
BUNKER GEAR INCLUDING A NIOSH POSITIVE PRESSURE SELF CONTAINED
BREATHING APPARATUS. COOL CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR ACCUMULATING
IN LOW AREAS & TRAVELING ALONG THE GROUND AWAY FROM THE HANDLING
SITE. DO NOT WELD, HEAT OR DRILL NEAR CONTAINER.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT, ELIMINATE SOURCES
OF IGNITION, ISOLATE AREA & DENY ENTRY. DIKE TO RETAIN LARGE SPILL.
REMOVE WITH VACUUM TRUCK OR PUMP TO STORAGE/SALVAGE VESSEL. SOAK UP
RESIDUE WITH INERTMATERIAL & FLUSH AREA WITH WATER TO REMOVE
RESIDUE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA AWAY FROM SOURCES OF IGNITION. ALL HANDLING EQUIPMENT MUST BE
GROUNDED TO PREVENT SPARKING.
Other Precautions:DANGER. EXTREMELY FLAMMABLE. AVOID ALL IGNITION
SOURCES & STRONG OXIDIZING AGENTS. HARMFUL OR FATAL IF SWALLOWED.
DO NOT SIPHON GAS BY MOUTH. FOR USE AS A MOTOR FUEL ONLY. DO NOT
USE AS A CLEANING SOL VENT OR FOR OTHER NON-MOTOR FUEL USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:UNDER CONDITIONS OF POTENTIAL HIGH EXPOSURE, USE
A NIOSH/MSHA APPROVED RESPIRATOR IS RECOMMENDED, PER CURRENT 29 CFR
1910.134 OR 29 CFR 1910.1028 USE EITHER AN ATMOSPHERE-SUPPLYING
RESPIRATOR OR AIR-P URIFYING RESPIRATOR FOR ORGANIC VAPORS.
Ventilation:USE EXPLOSION-PROOF VENTILATION AS REQUIRED TO CONTROL
VAPOR CONCENTRATIONS.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH. WEAR IMPERVIOUS
PROTECTIVE TYPE WORK CLOTHING (NITRILE RUBBER, POLYVINYL ALCOHOL,
NEOPRENE)
Work Hygienic Practices:WASH AFTER HANDLING & BEFORE EATING, DRINKING,
SMOKING OR USING TOILET. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
NOTE TO PHYSICIAN: IF MORE THAN 2.0 ML PER KG HAS BEEN INGESTED &
VOMITING HAS NOT OCCURRED, EMESIS SHOULD BE INDUCED WITH MEDICAL
SUPERVISION. KEEP VICTIM'S HEAD BELOW HIPS TO PREVENT ASPIRATION.
IFSYMPTOMS SUCH AS LOSS OF GAG REFLEX, CONVULSION, ETC OCCUR
BEFORE EMESIS, GASTRIC LAVAGE SHOULD BE CONSIDERED.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:100F,38C
Vapor Pres:7-14.5 PSI
Vapor Density:3.5
Spec Gravity:0.72-0.76
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BRONZE COLOR; CLEAR AND BRIGHT LIQUID. HYDROCARBON
ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID HEAT, SPARKS, OPEN FLAMES. PREVENT
VAPOR ACCUMULATION.
Hazardous Decomposition Products:CARBON MONOXIDE AND OTHER UNIDENTIFIED
ORGANIC COMPOUNDS CAN BE FORMED UPON COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:PRODUCT RECOVERY & RECYCLING IS RECOMMENDED.
DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ALLOY S (2635)
CAGE:FO783
CAGE:80357
CAGE:FO783
============= Composition/Information on Ingredients =============
Ingred Name:LANTHANUM
CAS:7439-91-0
Fraction by Wt: 0.05%
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 0.5%
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
Fraction by Wt: 14.5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9293
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 67%
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: 0.4%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:TUNGSTEN
CAS:7440-33-7
RTECS #:YO7175000
Fraction by Wt: 1%
OSHA PEL:5 MG/M3/ 10 STEL
ACGIH TLV:5 MG/M3/10 STEL;9192
Ingred Name:ALUMINUM (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 0.25%
OSHA PEL:15MG/M3 DUST/5 FUME
ACGIH TLV:10MG/M3 DUST; 9192
Ingred Name:BORON
CAS:7440-42-8
RTECS #:ED7350000
Fraction by Wt: 0.015%
Ingred Name:COBALT (SARA III)
CAS:7440-48-4
RTECS #:GF8750000
Fraction by Wt: 2.0%
Other REC Limits:0.05 PPM
OSHA PEL:0.1 MG/M3;AS CO
ACGIH TLV:0.05 MG/M3;DUST 9293
Ingred Name:CHROMIUM (SARA III)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 15.5%
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:IRON OXIDE
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 3%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INHALATION: METAL DUST/FUMES MAY CAUSE
MUCOUS MEMBRANE IRRITATION, RESPIRATORY IRRITATION, COUGH,
BRONCHITIS, CHILLS, FUME FEVER, & ASTHMA-LIKE SYMPTOMS. SKIN:
IRRITATION, ALLERGIC REACTION, & DERMATI TIS. EYES: PARTICULATE
IRRITATION/MECHANICAL INJURY TO COREA/CONJUNCTIVA. INGESTION:
IRRITATION.
Explanation of Carcinogenicity:CHROMIUM & NICKEL ARE CONSIDERED TO BE A
CARCINOGEN.
Effects of Overexposure:INHALATION: RESPIRATORY DISEASE, SHORTNESS OF
BREATH, COUGH, PERMANENT DISABILITY, SERIOUS LUNG INJURY, FIBROSIS,
EFFECTS ON HEART, CNS DEPRESSION, NASAL, BRONCHIAL, LUNG CANCERS,
GASTRO-INTESTINAL DI SORDERS, CHANGES IN LUNGS, MUCOUS MEMBRANE
IRRITATION. SKIN/EYES: INJURY.
Medical Cond Aggravated by Exposure:ALLERGIC REACTION OR SENSITIVITY TO
METALS, PULMONARY FUNCTION, AIRWAY DISEASE, ASTHMA, EMPHYSEMA,
CHRONIC BRONCHITIS, DAMAGE/DISEASE TO NERVOUS, CIRCULATORY,
HEMATOLOGIC, RENAL SYSTEMS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/COPIOUS AMOUNTS OF CLEAN WATER. SKIN: TREAT
CUT/ABRASIONS BY STANDARD FIRST AID. CONTAMINATION BY DUST/POWDER
CAN BE REMOVED BY SOAP & WATER. INGESTION: DRINK LARGE QUANTITIES
OF WATER. INDUCE VOMITING IF CONSCIOUS. INHALATION: REMOVE TO
FRESH AIR. IF BREAATHING STOPPED, PERFORM ARTIFICIAL RESPIRATION.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:THESE ALLOYS ARE NONCOMBUSTIBLE. USE EXTINGUISHING
MEDIA APPROPRIATE TO THE SURROUNDING FIRE.
Fire Fighting Procedures:TO EXTINGUISH A METAL POWDER FIRE USE DRY
SAND, DRY GRAPHITE, OR OTHER CLASS D FIRE EXTINGUISHING POWDER.
Unusual Fire/Explosion Hazard:IF MATERIALS ARE REDUCED TO POWDER FORM,
CAUTION MUST BE USED TO PREVENT FIRE/EXPLOSION. EVOLUTION OF
HYDROGEN MAY BE AN EXPLOSION HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:IN SOLID FORM MATERIALS POSE NO SPECIAL
CLEAN-UP PROBLEMS. IF MATERIAL IS IN POWDER/DUST FORM, CLEAN-UP
SHOULD BE CONDUCTED W/VACUUM SYSTEM UTILIZING A HIGH EFFICIENCY
PARTICULATE AIR FILTRATION SYSTE M. AVOID CONTAMINATION OF AIR &
WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE ACCORDING TO SIZE
SHAPE/QUANTITY OF MATERIAL INVOLVED. SOLID METAL MAY REQUIRE USE OF
HOISTS/CRANES, ETC. STORE METAL/METAL POWDER IN DRY AREA.
Other Precautions:DON'T STORE ADJACENT TO MINERAL ACIDS. FINE METAL
POWDER SHOULD BE KEPT AWAY FORM FLAMES & SOURCES OF IGNITION. AVOID
BREATHING DUST OR FUME.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATORS. LUNG FUNCTION
TESTS ARE RECOMMENDED FOR USERS OF NEGATIVE PRESSURE DEVICES. USE
FUME RESPIRATOR OR AN AIR SUPPLIED RESPIRATOR TO KEEP <TLV.
Ventilation:PROVIDE LOCAL EXHAUST VENTILATION TO KEEP DUST & FUME <TLV.
Other Protective Equipment:UNIFORMS, DISPOSABLE COVERALLS, SAFETY SHOES
Supplemental Safety and Health
HEAT RESISTANT ALLOY PRODUCTS MAY CONTAIN VARYING CONCENTRATIONS, FROM
ELEMENTAL CONTITUENTS, ALUMINUM, COBALT, CHROMIUM, COPPER, IRON,
MANGANESE, MOLYBDENUM, NICKEL, & TUNGSTEN. WELDING, THERMAL CUTT
ING, GRINDING & MELTING THIS PRODUCT MAY PRODUCE CHEMICALS KNOWN TO
THE STATE OF CALIFORNIA TO CAUSE CANCER.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text: 2435F
Solubility in Water:INSOLUBLE
Appearance and Odor:SOLID-SILVER GRAY COLOR, NO ODOR
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MINERAL ACIDS, OXIDIZING AGENTS
Stability Condition to Avoid:FLAMES, SOURCES OF IGNITION
Hazardous Decomposition Products:HYDROGEN GAS, VARIOUS ELEMENTAL
METALS/METAL OXIDES,
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:METCO 71NS
CAGE:FO878
CAGE:FO878
CAGE:39918
============= Composition/Information on Ingredients =============
Ingred Name:TUNGSTEN
CAS:7440-33-7
RTECS #:YO7175000
OSHA PEL:5 MG/M3/ 10 STEL
ACGIH TLV:5 MG/M3/10 STEL;9192
Ingred Name:GRAPHITE, SYNTHETIC
CAS:7440-44-0
RTECS #:FF5250100
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9293
Ingred Name:COBALT (SARA III)
CAS:7440-48-4
RTECS #:GF8750000
Other REC Limits:0.05 PPM
OSHA PEL:0.1 MG/M3;AS CO
ACGIH TLV:0.05 MG/M3;DUST 9293
Ingred Name:IRON OXIDE
CAS:1309-37-1
RTECS #:NO7400000
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: DUST IRRITATION, CONJUNCTIVITIS
EPITHELIA HYPERPLASIA OF CORNEA, EYELID INFLAMMATION. INHALATION:
COUGH, DYSPNEA, DECREASED PULMONARY FUNCTION, PNEUMOCONIOSIS, LOW
WEIGHT, DIFFUSE NODULAR FIBROS IS, RESPIRATORY
HYPERSENSITIVITY/IRRITATION, & MUCOUS MEMBRANES IRRITATION. SKIN:
IRRITATION, & DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: POSSIBLE IRRITATION. INHALATION:
RESPIRATORY IRRITATION. SKIN: POSSIBLE DERMATITIS. INGESTED:
POSSIBLE IRRITATION.
Medical Cond Aggravated by Exposure:CONSULT A PHYSICIAN.
======================= First Aid Measures =======================
First Aid:EYES: FLOOD EYE WITH WATER. IF IRRITATION PERSISTS, CONSULT A
PHYSICIAN.SKIN: IF IRRITATION OCCURS, WASH W/SOAP & WATER TO
REMOVE POWDER. INHALATION: EXPOSE TO FRESH AIR. INGESTION: CONSULT
A PHYSIC IAN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE CLASS D FIRE EXTINGUISHER.
Fire Fighting Procedures:TREAT AS A METALLIC FIRE.
Unusual Fire/Explosion Hazard:MODERATE FIRE HAZARD IN THE FORM OF DUST
WHEN EXPOSED TO FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:MATERIAL THAT IS SPILLED ONTO THE FLOOR MAY
BECOME AIRBORNE BY NORMAL PLANT ACTIVITY. GOOD HOUSEKEEPING, BY
SWEEPING THE AREA CLEAN, IS NECESSARY TO REMOVE THESE MATERIALS
FROM BECOMING A SOURCE OF AI R CONTAMINATION.
Neutralizing Agent:NO INFORMATION GIVEN ON MSDS BY SUPPLIER
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM INCOMPATABLES IN A
COOL DRY AREA.
Other Precautions:AVOID ORAL INGESTION AND EXCESSIVE SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A RESPIRATOR APPROVED BY NIOSH FOR DUST, FUMES &
MISTS SHOULD BE WORN DURING THE THEMRAL SPRAY PROCESS TO PROTECT
OPERATOR FROM DUST AND FUMES.
Ventilation:USE EQUIPMENT DESIGNED TO PROVIDE AN AIR VELOCITY OF 200
FPM.
Other Protective Equipment:ALUMINIZED APRON, EYE WASH STATION, EAR
PROTECTION WHERE REQUIRED.
Work Hygienic Practices:SUPPLIER DID NOT ADDRESS THIS FIELD.
Supplemental Safety and Health
MSDS RECEIVED FROM NAVY (FOCAL POINT N). NAVY IDENTIFIED NSN.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:2200-2800F
Solubility in Water:NEGLIGIBLE
Appearance and Odor:POWDER; NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS
Stability Condition to Avoid:SUPPLIER DID NOT ADDRESS THIS FIELD.
Hazardous Decomposition Products:OZONE, NITRIC OXIDE FROM PLASMA FLAME.
(INDEPENDENT OF POWDER)
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TURBO FUEL A
CAGE:DO850
CAGE:0PHE6
CAGE:29700
CAGE:DO850
============= Composition/Information on Ingredients =============
Ingred Name:HYDROTREATED LIGHT PETROLEUM DISTILLATE
CAS:64742-47-8
Fraction by Wt: 100%
Other REC Limits:EXXON:100 PPM/8-HOUR
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS 5000 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-MAY CAUSE GASPING,NAUSEA &
DISORIENTATION.INHALATION OF HIGH VAPOR CONCENTRATIONS MAY CAUSE
MILD DEPRESSION,IRRITATION & POSSIBLY DEATH.PROLONGED/REPEATED SKIN
CONTACT MAY CAUSE IRRITATION & DER MATITIS.EYE CONTACT MAY CAUSE
IRRITATION.ORALLY HAS LOW TOXICITY BUT HAS ASPIRATION
HAZARD.CHRONIC-MAY CAUSE DERMATITIS.
Explanation of Carcinogenicity:LONG-TERM, REPEATED EXPOSURE MAY CAUSE
SKIN CANCER.
Effects of Overexposure:MAY CAUSE GASPING, NAUSEA & DISORIENTATION.
INHALATION OF HIGH VAPOR CONCENTRATIONS MAY CAUSE MILD DEPRESSION,
IRRITATION & POSSIBLY DEATH. PROLONGED/REPEATED SKIN CONTACT MAY
CAUSE IRRITATION & DERMA TITIS. EYE CONTACT MAY CAUSE IRRITATION.
ORALLY HAS LOW TOXICITY BUT HAS ASPIRATION HAZARD.
Medical Cond Aggravated by Exposure:SKIN CONTACT MAY AGGRAVATE AN
EXISTING DERMATITIS.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST.SKIN:WASH WITH SOAP
& WATER.EYE:FLUSH WITH WATER FOR 15 MINUTES,HOLDING EYELIDS
OPEN.INHALED:REMOVE TO FRESH AIR & PROVIDE OXYGEN/CPR IF
NEEDED.ORAL:DO NOT IN DUCE VOMITING. GET MEDICAL ATTENTION
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:100F,38C
Autoignition Temp:Autoignition Temp Text:410F
Lower Limits:0.9
Upper Limits:7
Extinguishing Media:WATER SPRAY, CO2, FOAM/DRY CHEMICAL. WATER SPRAY
MAY BE USED TO KEEP FIRE EXPOSED CONTAINERS COOL & FLUSH SPILLS
AWAY.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS WITH FULL
FACEPIECE OPERATED IN THE POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:FUMES, SMOKE, CARBON MONOXIDE, CARBON
DIOXIDE, ALDEHYDES AND OTHER DECOMPOSITION PRODUCTS. VAPORS MAY
SETTLE IN LOW AREAS & TRAVEL TO IGNITION SOURCE & IGNITE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE THE AREA. CONTAIN THE SPILL. PICK UP LARGE
SPILL WITH NON-SPARKING TOOLS; SMALL SPILLS/RESIDUE WITH INERT
ABSORBENT MATERIAL. PLACE IN CONTAINERS. PREVENT ENTERING
WATERWAYS/SEWERS.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE-STORE IN COOL,VENTILATED
AREA,IN TIGHTLY CLOSED CONTAINERS,AWAY FROM HEAT,FLAMES &
OXIDIZERS.
Other Precautions:"EMPTY" CONTAINERS RETAIN RESIDUE AND CAN BE
DANGEROUS. DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL,
GRIND OR EXPOSE SUCH CONTAINERS TO HEAT,FLAME,SPARKS. THEY MAY
EXPLODE AND CAUSE INJURY/DEAT H. AVOID REPEATED/PROLONGED SKIN
CONTACT
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE ONLY WITH ADEQUATE VENTILATION. USE
NIOSH-APPROVED SUPPLIED-AIR RESPIRATORY PROTECTION IN CONFINED OR
ENCLOSED SPACES.
Ventilation:USE LOCAL EXHAUST TO MAINTAIN EXPOSURE BELOW TLV/PEL IF
NORMAL ROOM VENTILATION IS NOT SUFFICIENT. NO SMOKING OR FLAME.
Other Protective Equipment:IMPERVIOUS CLOTHING AS NEEDED TO PREVENT
PROLONGED/REPEATED CONTACT, EYE WASH STATION, EMERGENCY SHOWER
Work Hygienic Practices:USE GOOD INDUSTRIAL HYGIENE PRACTICE. AVOID
UNNECESSARY CONTACT. DO NOT BREATHE VAPORS OR MIST.
Supplemental Safety and Health
PRODUCT CODE 120400-00072.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text: 320F,160C
Melt/Freeze Pt:M.P/F.P Text:-40F,-40C
Vapor Pres:<5
Vapor Density:>5
Spec Gravity:.7753 - .8398
Evaporation Rate & Reference:<0.1 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, WATER-WHITE LIQUID, FAINT PETROLEUM
HYDROCARBON ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS SUCH AS LIQUID CHLORINE, CONCENTRATED OXYGEN, SODIUM
HYPOCHLORITE, CALCIUM HYPOCHLORITE, ETC.
Stability Condition to Avoid:HEAT, SPARKS, IGNITION SOURCES, OPEN
FLAMES, STATIC ELECTRICITY, PILOT LIGHTS
Hazardous Decomposition Products:FUMES, SMOKE, CARBON MONOXIDE, CARBON
DIOXIDE, ALDEHYDES AND OTHER DECOMPOSITION PRODUCTS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL FEDERAL, STATE
AND LOCAL REGULATIONS. INCINERATION IS RECOMMENDED. THE RQ FOR
NAPHTHALENE IS 100 POUNDS. THIS PRODUCT CONTAINS APPROXIMATELY 3.0
% NAPHTHALENE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:JBW/AND 1996 POTASSIUM ACETATE RUNWAY DEICER
Resp. Party Other MSDS Num.:8043
CAGE:7U402
Contract Num:SP0450-96-D-4086-004Z
CAGE:0VTU2
CAGE:7U402
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM ACETATE
CAS:127-08-2
RTECS #:AJ3325000
= Wt:50.
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
= Wt:50.
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE PROVIDED BY MFR.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE EYE, SKIN, AND RESPIRATORY
IRRITATION. INGESTION MAY RESULT IN IRRITATION OF THE MUCOUS
MEMBRANES AND GASTROINTESTINAL TRACT. MAYBE CORROSIVE TO BODY
TISSUES.
Explanation of Carcinogenicity:NONE OF THE INGREDIENTS ARE KNOWN LISTED
CARCINOGNS
Effects of Overexposure:NONE PROVIDED BY MFR. IRRITATION, BURNS,
ITCHING, REDNESS.
Medical Cond Aggravated by Exposure:ASTHMA, CHRONIC RESPIRATORY
DISEASE, EYE DISEASES, SKIN DISORDERS, AND SOME ALLERGIES.
======================= First Aid Measures =======================
First Aid:IF SWALLOWED: IF VICTIM IS ALERT AND NOT CONVULSING, GIVE ONE
GLASS OF WATER TO DILUTE MATERIAL. DO NOT INDUCE VOMITING. SEEK
IMMEDIATE MEDICAL ATTENTION. IF INHALED: MOVE VICTIM TO FRESH AIR.
SEEK ME DICAL ATTENTION IF IRRITATION PERSISTS. EYES: IMMEDIATELY
FLUSH WITH WATER FOR AT LEAST 15 MINS. SEEK MEDICAL ATTENTION IF
IRRITATION PERSISTS. SKIN: WASH AFFECTED AREAS WITH SOAP AND WATER.
SEEK MEDI CAL ATTENTION IF IRRITATION PERSISTS.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Extinguishing Media:USE WATER OR OTHER AGENT SUITABLE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND SELF
CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:DECOMPOSITION PRODUCTS MAY BE TOXIC
================== Accidental Release Measures ==================
Spill Release Procedures:COLLECT SPILLED PRODUCT AND STORE TO REUSE.
CONTAMINATED PRODUCT AND/OR ENVIRONMENTAL MEDIA SHOULD BE RECOVERED
AND DISPOSED OF PROPERLY.
Neutralizing Agent:NONE PROVIDED BY MFR.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH SKIN AND EYES.
Other Precautions:NONE PROVIDED BY MFR.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR WITH ORGANIC VAPOR CARTRIDGE
RECOMMENDED
Ventilation:LOCAL EXHAUST VENTILATION RECOMMENDED
FACESHIELD
Other Protective Equipment:NONE PROVIDED BY MFR.
Work Hygienic Practices:NONE PROVIDED BY MFR. WASH THOROUGHLY BEFORE
EATING/DRINKING/SMOKING & AT END OF WORKDAY.
Supplemental Safety and Health
NONE PROVIDED BY MFR.
================== Physical/Chemical Properties ==================
HCC:B3
Decomp Temp:Decomp Text:NONE PROVIDED BY MFR.
Spec Gravity:1.281
pH:9.2
Viscosity:NONE PROVIDED BY MFR.
Solubility in Water:COMPLETELY SOLUBLE
Appearance and Odor:LIGHT BLUE LIQUID WITH SLIGHT ODOR (BULK DENSITY=
10.66 LBS/GAL)
Percent Volatiles by Volume:NONE PROVIDE
Corrosion Rate:NONE PROVIDED BY MFR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIS, STRONG REDUCING AGENTS, HYPOCHLORITES; AMINES, HEAT
Stability Condition to Avoid:STRONG ACIDS, ALUMINUM, TIN, ZINC, AND
ALLOYS, LEATHER AND WOOL, ORGAINCS
Hazardous Decomposition Products:CO2, CO, AND ORGANIC ACIDS
Conditions to Avoid Polymerization:WILL NOT OCCUR
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE
AND LOCAL REGULATIONS. REUSE RECOVERED PRODUCT WHERE POSSIBLE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LIQUID HI-CHLOR, 79087
CAGE:0DAC4
CAGE:0DAC4
CAGE:85884
============= Composition/Information on Ingredients =============
Ingred Name:HYPOCHLOROUS ACID, SODIUM SALT; (SODIUM HYPOCHLORITE)
(CERCLA). %: 8.4-10.5.
CAS:7681-52-9
RTECS #:NH3486300
Fraction by Wt: <10.5%
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN & EYES:CAUSES CHEMICAL BURNS. EYE
CONTACT MAY CAUSE BLINDNESS. INGEST:HARMFUL. CAUSES CHEMICAL BURNS
OF MOUTH, THROAT & STOMACH. INHAL:VAPORS OR MIST CAUSE IRRITATION,
INCLUDING A BURNING TASTE,SNEEZING, COUGHING & DIFFICULTY
BREATHING.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PEOPLE W/ASTHMA OR OTHER LUNG
PROBLEMS MAY BE MORE AFFECTED.
======================= First Aid Measures =======================
First Aid:EYES:IMMED FLUSH W/PLENTY OF COOL RUNNING WATER. REMOVE CONT
LENSES. CONTINUE FLUSHING FOR AT LST 15 MINS, HOLDING EYELIDS APART
TO ENSURE RINSING OF ENTIRE EYE. CALL MD IMMED. SKIN:IMMED FLUSH
W/PLEN TY OF COOL RUNNING WATER FOR AT LST 15 MINS WHILE REMOVING
CONTAM CLTHG & SHOES. WASH CLTHG BEFORE REUSE. INGEST:RINSE MOUTH
AT ONCE; THEN DRINK 1-2 LG GLASSES OF WATER/MILK. DO NOT INDUCE
(SUPDAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE . PRODUCT DOES
NOT SUPPORT COMBUSTION.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PROTECTIVE EQUIPMENT. DIKE OR DAM
SPILLS. PUMP TO CONTAINERS OR SOAK UP ON INERT ABSORBENT. FLUSH
RESIDUE TO SANITARY SEWER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING DUSTS OR MISTS OF THIS
PRODUCT.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PH (1%):10.5. FIRST AID PROC:VOMIT. NEVER GIVE ANYTHING BY MOUTH TO
UNCON PERS. INHAL:IMMED MOVE TO FRESH AIR. CALL POIS CTL CTR/MD
FA CESHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Spec Gravity:1.16-1.17
pH:SUPDAT
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIGHT YELLOW LIQUID W/CHLORINE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MIX ONLY W/WATER. DO NOT MIX W/ACIDS OR AMMONIA - WILL CAUSE HAZARDOUS
VAPORS.
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:HIGH TEMPERATURES MAY GENERATE
HAZARDOUS DECOMPOSITION PRODUCTS INCLUDING CHLORINE GAS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . UNUSED PRODUCT AS A WASTE IS CORROSIVE (D002) BY RCRA
CRITERIA.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: TROUNCE CREAM PUMICE HAND CLEANER, 03506
Cage: 7K128
=======================================================
Contractor Summary
=======================================================
Cage: 7K128
Cage: 62377
=======================================================
Ingredients
=======================================================
Cas: 8052-41-3
RTECS #: WJ8925000
% Wt: 35-40
OSHA PEL: 500 PPM
ACGIH TLV: 100 PPM
------------------------------
Cas: 7732-18-5
RTECS #: ZC0110000
% Wt: 30-35
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 1332-09-8
% Wt: 7-13
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 61790-45-2
% Wt: 3-8
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 68132-50-3
% Wt: 3-8
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 68154-97-2
% Wt: 3-8
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 64742-65-0
RTECS #: PY8038501
REFINING &/OR HYDROTREATMENT); (MINERAL OIL)
% Wt: 2-5
OSHA PEL: N/K (FP N)
ACGIH TLV: 10 MG/M3 (MIST)(MFR)
------------------------------
Cas: 14808-60-7
RTECS #: VV7330000
% Wt: 0.1-1
OSHA PEL: 10 MG/M3 RDUST
ACGIH TLV: 0.1 MG/M3 RDUST
------------------------------
RTECS #: 9999999VO
% Wt: SEE ING
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50:(ORAL) >5,000 MG/KG.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: NONE UNDER NORMAL CONDITIONS OF USE. OVEREXPOSURE MAY
CAUSE EYE OR RESPIRATORY SYSTEM IRRITATION; HEADACHE, NAUSEA, DIZZINESS,
WEAKNESS, FATIGUE, UNCONSCIOUSNESS; VOMITING, DIARREHA; EYE REDNESS, TEAR
ING, BLURRED VISION. EYE IRRITANT. MAY IRRITATE RESPIRATORY SYSTEM UPON
FREQUENT OR PROLONGED USE. HIGH(EFTS OF OVEREXP)
Explanation Of Carcinogenicity: SILICA, CRYSTALLINE-QUARTZ:IARC MONOGRAPHS,
SUPP, VOL 7, PG 341, 1987:GRP 2A. NTP 6TH ANNUAL RPT ON CARCINS, (SUPP DATA)
Signs And Symptions Of Overexposure: HLTH HAZ:CONCENTRATIONS MAY IRRITATE EYES
& RESPIRATORY SYSTEM. MATERIAL VOMITED AFTER INGESTION & ASPIRATED
INTO LUNGS MAY CAUSE BRONCOPNEUMONIA OR PULMONARY EDEMA.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INGEST:DO NOT INDUCE VOMITING. CALL MD IMMEDIATELY. INHAL:REMOVE TO
FRESH AIR. IF SYMPTOMS PERSIST, OBTAIN MEDICAL ATTENTION. SKIN:FLUSH W/WATER.
EYES:FLUSH FOR AT LEAST 15 MINUTES W/WATER. CALL MD IM MEDIATELY.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: RINSE AWAY W/WATER OR WIPE UP W/TOWEL.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS (FP N). ARRANGE FOR DISPOSAL W/CHEMICAL WASTE HANDLER LICENSED
FOR DEALING W/IGNITABLE WASTE.
Handling And Storage Precautions: HAND CLEANER SHOULD BE STORED BETWEEN 40F
& 100F IN ORDER TO INSURE LONG LIFE OF THE EMULSION. KEEP AWAY FROM
SPARKS OR OPEN FLAMES.
Other Precautions: FOLLOW ALL GENERAL SAFETY PRECAUTIONS. KEEP AWAY FROM
CHILDREN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point Text: 110F,43C
Extinguishing Media: CARBON DIOXIDE, CHEMICAL POWDER.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N).
Ventilation: SUFFICIENT TO MAINTAIN VAPOR CONCENTRATIONS BELOW TLV.
Other Protective Equipment: NONE NORMALLY NEEDED.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: EXPLAN OF CARCIN:1991:ANTICIPATED TO BE
CARCINOGEN.
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 0.95
PH: 8.6
Solubility in Water: SOLUBLE
Appearance and Odor: BLUE CREAM W/MINERAL SCRUBBER; PLEASANT SMELLING ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NONE.
Hazardous Decomposition Products: FORMED BY FIRE/THERMAL DECOMPOSITION:
IRRITATING ORGANIC VAPORS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: TROUNCE CREAM PUMICE HAND CLEANER, 03506
Cage: 7K128
Company Name: LOCTITE CORP
Street: 705 N MT RD
Zipcode: 06111
Label Required IND: Y
Date Of Label Review: 08/19/1994
Status Code: C
Label Date: 08/19/1994
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: KEEP FROM SPARK OR FLAME. ACUTE:NONE UNDER NORMAL
CONDITIONS OF USE. OVEREXPOSURE MAY CAUSE EYE OR RESPIRATORY SYSTEM
IRRITATION; HEADACHE, NAUSEA, DIZZINESS, WEAKNESS, FATIGUE, UNCONSCIOUSNESS;
VOMIT ING, DIARREHA; EYE REDNESS, TEARING, BLURRED VISION. EYE IRRITANT. MAY
IRRITATE RESPIRATORY SYSTEM UPON FREQUENT OR PROLONGED USE. HIGH
CONCENTRATIONS MAY IRRITATE EYES & RESPIRATORY SYSTEM. MATERIAL VOMITED
AFTER INGESTION & ASPIRATED INTO LUNGS MAY CAUSE BRONCHOPNEUMONIA OR
PULMONARY EDEMA. CHRONIC:CANCER HAZARD. CONTAINS CRYSTALLINE SILICA QUARTZ
WHICH IS LISTED AS A CARCINOGEN (FP N).
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:9005 GENERAL PURPOSE CLEANER 1
CAGE:GO712
CAGE:1S791
CAGE:GO712
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL(IARC-GROUP 3) *97-4*
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 5%
Other REC Limits:400 PPM
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
Ingred Name:POTASSIUM HYDROXIDE, KOH
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: <1%
Other REC Limits:2 MG/CUM (CEILING)
ACGIH TLV:2 MG/CUM (CEILING)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:POTASSIUM HYDROXIDE MAY CAUSE CHEMICAL
BURNS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:DIZZINESS, HEADACHES, NAUSEA, BURNS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SKIN: FLUSH W/COLD WATER.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:116.2F
Extinguishing Media:CO2, DRY CHEMICAL.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T ALLOW TO FREEZE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:213F
Spec Gravity:1.06
Solubility in Water:COMPLETE
Appearance and Odor:TRANSPARENT BLUE W/MILD ODOR
Percent Volatiles by Volume:90.5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS.
Stability Condition to Avoid:FREEZING.
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH TO DRAIN W/WATER, IAW/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LANTHANUM ATOMIC ABSORPTION STANDARD-1,000 UG/ML
CAGE:JO132
CAGE:JO132
CAGE:0RP29
============= Composition/Information on Ingredients =============
Ingred Name:LANTHANUM (III) NITRATE, HEXAHYDRATE (1:3:6); (LANTHANUM)
CAS:10277-43-7
RTECS #:OE5250000
Fraction by Wt: 0.1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:NITRIC ACID (SARA 302/313) (CERCLA)
CAS:7697-37-2
RTECS #:QU5775000
Fraction by Wt: 5%
OSHA PEL:2 PPM
ACGIH TLV:2 PPM/4 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: BALANCE
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION:MAY CAUSE BREATHING
DIFFICULTIES LEADING TO PNEUMONIA AND PULMONARY EDEMA. SYMPTOMS
INCLUDE COUGHING, CHOKING AND IRRITATION OF THE NOSE, THROAT AND
RESPIRATORY TRACT. SKIN/EYE CONTACT:SEVE RE IRRITATION. SKIN
ABSORPTION:NONE IDENTIFIED. INGESTION:BURNS TO MOUTH, THROAT AND
STOMACH, NAUSEA, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:VOMITING, KIDNEY DISFUNCTION.
CHRONIC:LUNG DAMAGE, KIDNEY DAMAGE, DAMAGE TO LUNGS, TEETH. TARGET
ORGANS:EYES, SKIN, MUCOUS MEMBRANES, RESPIRATORY SYSTEM, LUNGS,
KIDNEYS, BLOOD, PROSTATE, TEE TH, GI TRACT.
Medical Cond Aggravated by Exposure:DAMAGED SKIN, EYE DISORDERS,
CARDIOPULMINARY DISEASE, LUNG DISEASE.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD. DO NOT INDUCE VOMIT. IF CONSCIOUS, GIVE
WATER, MILK/MILK OF MAGNESIA. INHAL:REMOVE TO FRESH AIR. IF NOT
BRTHG, GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE OXYG. SKIN:IMMED
FLUSH W/PLENTY O F WATER FOR @ LST 15 MIN WHILE REMOVINGCONTAM
CLTHG & SHOES. WASH CLTHG BEFORE RE-USE. EYES:IMMED FLUSH W/PLENTY
OF WATER FOR @ LST 15 MIN.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:REACTS WITH MOST METALS TO PRODUCE
HYDROGEN GAS, WHICH CAN FORM EXPLOSIVE MIXTURE WITH AIR. TOXIC
GASES PRODUCED:OXIDES OF NITROGEN.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT CLTHG.
STOP LEAK IF YOU CAN DO SO W/OUT RISK. VENT AREA. NEUT SPILL W/SODA
ASH OR LIME. WITH CLEAN SHOVEL, CAREFULLY PLACE MATERIAL INTO
CLEAN, DRY CONTAINER & COVER. REMOVE FROM AREA. FLUSH SPILL AREA
W/WATER.
Neutralizing Agent:SODA ASH OR LIME.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN SECURE POISON AREA. ISOLATE FROM INCOMPATIBLE MATERIALS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:VENT HOOD.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH & DELUGE
SHOWER . LAB COAT AND APRON.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EYE PROT:AND FULL LENGTH FACE SHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Spec Gravity:1 (H*2O=1)
Solubility in Water:COMPLETE (100%)
Appearance and Odor:COLORLESS LIQUID. ODORLESS.
Percent Volatiles by Volume:99
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES, STRONG REDUCING AGENTS, ALKALIES, MOST COMMON METALS
Stability Condition to Avoid:HEAT.
Hazardous Decomposition Products:OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE & LOCAL ENVIRONMENTAL REGULATIONS. RQ:ING 2:1,000
LBS. EPA HAZ WASTE #:D002 (CORROSIVE WASTE).
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PRIMARY COLOR-3 CRES-LITE METALLIC PIGMENT
Preparer's Name:STEPHEN FUGLSANG
CAGE:EO514
CAGE:EO514
============= Composition/Information on Ingredients =============
Ingred Name:STEARIC ACID
CAS:57-11-4
RTECS #:WI2800000
Fraction by Wt: 0.5-2%
Ingred Name:ISOSTEARIC ACID
CAS:30399-84-9
Fraction by Wt: 0.5-2%
Ingred Name:ALUMINUM (POWDER) *95-4*
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 98-99%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: ALUMINUM DUSTS CAN CAUSE
IRRITATION. INHALATION: PROLONGED EXPOSURE TO AIRBORN PARTICULATE
MAY CAUSE IRRITATION OF THE NOSE & TRACHEA RESULTING IN NASAL
ULCERATION. INGESTION: ALUMINUM ISN' T CONSIDERED NON-TOXIC.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, METALLIC TASTE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR 15 MINS. SKIN: WASH AREA
W/SOAP & WARM WATER. INHALATION: REMOVE TO FRESH AIR. IF BREATHING
HAS STOPPED, BEGIN ARTIFICIAL RESPIRATION PROCEDURE AT ONCE.
INGESTION: DR INK 1/2 GLASSES OF WATER. DON'T INDUCE VOMITING.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Lower Limits:(SUPP)
Fire Fighting Procedures:WEAR SCBA. NEVER EMPLOY WATER/HIGH VELOCITY
DRY CHEMICAL ON AN ALUMINUM FIRE. SAND/ANOTHER INERT MATERIAL
SHOULD BE USED TO RING/DIKE FIRE TO EXTINGUISH ITSELF.
Unusual Fire/Explosion Hazard:ALUMINUM POWDER IN BULK FORM IS STABLE,
BUT WHEN SUSPENDED AS AIRBORNE PARTICULATE, IT CAN BE POTENTIALLY
EXPLOSIVE.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: SWEEP GENTLY INTO A HAZARDOUS WASTE
CONTAINER. AVOID GENERATING DUST CLOUDS. USE NON-SPARKING TOOLS.
LARGE: HANDLE AS A SMALL SPILL. AVOID RUN-OFF INTO SEWERS,
DRAINS/OTHER OPEN BODIES OF WATER .
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN AN AREA AWAY FROM EXTREME
TEMP CONDITIONS. KEEP CONTAINERS CLOSED & DRY AFTER USE. KEEP AWAY
FROM CHILDREN. HILDREN.
Other Precautions:ALUMINUM REACTS W/WATER WHICH WILL SLOWLY GENERATE
HYDROGEN GAS & HEAT. THIS REACTION CAN BE HAZARDOUS WHEN TRYING TO
STORE COMBINED PRODUCT IN A SEALED CONTAINER. DON'T STORE FINISHED
MIXTURES OF WAT ER THAT CONTAIN ALUMINUM FLARE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR AN APPROPRIATE (NIOSH APPROVED) RESPIRATOR
DURING APPLICATION IF AIR MONITORING DEMONSTRATES THAT AIRBORN
PARTICULATE EXCEEDS RECOMMENDED LIMITS.
Ventilation:SUFFICIENT IN VOLUME & PATTERN TO KEEP AIR QUALITY W/IN
APPROVED OSHA LEVELS.
Other Protective Equipment:EYE WASH & SAFETY SHOWER.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING. AVOID WEARING CONTACT
LENSES.
Supplemental Safety and Health
BOILING RANGE (ALUMINUM): 4766F. LEL: 0.035 OZ/CUFT. CHLORINATED
HYDROCARBONS/CARBON DISULFIDE/SODIUM PEROXIDE PLUS/C02/SULFUR
DICHLORIDE/PALLADIUM/MANGANESE/MAGNESIUM PLUS/POTASSIUM
CHLORATE/SODIUM C ARBONATE/SULFATES/DIBORNE. ALUMUNIM REACTS
W/WATER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:(SEE SUPP)
Spec Gravity:ALUMINUM 2.7
Appearance and Odor:SILVERY/GRAY METALLIC LOOKING POWDER W/LITTLE ODOR
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES/CHLORATES/BROMATES/MINERAL ACIDS/STRONG OXIDIZING
AGENTS/SILVER CHLORIDE/IODATES/NITRATES/WATER. (SUPP)
Stability Condition to Avoid:GENERATING DUST, HEAT
Hazardous Decomposition Products:HYDROGEN & NOXIOUS COPPER COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. ALUMINUM POWDER UN1309.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:402194, FRESH KOTE LATEX FLAT DEEP BASE
CAGE:85519
CAGE:85519
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: >3%
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 1-10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:CALCIUM CARBONATE. PEL: 15 MG/M3 TDUST; 5 MG/M3 RDUST
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 11-30%
OSHA PEL:SEE INGREDIENT NAME
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:DIATOMACEOUS EARTH
CAS:68855-54-9
Fraction by Wt: 1-10%
OSHA PEL:80 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CLAY (KAOLIN); (AL SILICATE). PEL: 10 MG/M3 TDUST; 5 MG/M3
RDUST.
CAS:1332-58-7
RTECS #:GF1670500
Fraction by Wt: 1-10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9293
Ingred Name:AL SILICATES
CAS:1327-44-2
OSHA PEL:3 MG/M3
ACGIH TLV:20 MPPCF
Ingred Name:ETHYLENE GLYCOL. VP: 0.1@25C. LEL: 3.2%
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 1-10%
OSHA PEL:50 PPM STEL, C
ACGIH TLV:50 PPM STEL, C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:NONHAZARDOUS INGREDIENTS CONSISTING OF INGREDIENTS 8-10
Ingred Name:STYRENE-ACRYLIC POLYMER
Fraction by Wt: >3%
Ingred Name:VINYL ACRYLIC RESIN; (VINYL ACETATE/ACRYLIC POLYMER)
CAS:25067-01-0
Fraction by Wt: >3%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: MAY CAUSE HEADACHE AND
NAUSEA. SKIN: POSSIBLE PRIMARY IRRITATION (MATERIAL IS SLIGHTLY
ALKALINE). EYE: PRIMARY IRRITATION. CHRONIC: NONE RECOGNIZED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM EXPOSURE. SKIN: REMOVE MATERIAL WITH SOAP
AND WATER. REMOVE CONTAMINATED CLOTHING. EYES: FLUSH IMMED WITH
LARGE AMOUNTS OF WATER FOR AT LEAST 15 MIN. CONSULT PHYSICIAN FOR
SPECIAL M EDICAL TREATMENT. INGEST: CALL MD IMMED.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Lower Limits:SEE ING 6
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO
BUILD- UP OF STEAM PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:COLLECT IN CONTAINER FOR DISPOSAL. CLEAN UP
WITH WATER BEFORE ALLOWING TO DRY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING. DO NOT STORE IN
SUN/ ABOVE 120F.
Other Precautions:DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF
CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD MECH FILTER RESP TO REMOVE
SOLID AIRBORNE PARTICLES OF OVERSPRAY DURING SPRAY APPLICATION.
Ventilation:MAINTAIN ADEQUATE VENTILATION TO ENSURE AIR ENTRY DURING
APPLICATION AND DRYING.
Other Protective Equipment:USE PROTECTIVE SKIN CREAM IF NEEDED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Pres:SEE ING 6
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHYL ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:66-69
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:IF INVOLVED IN FIRE (FROM OTHER
SOURCES) COULD CONCEIVABLY RSLT IN REL OF CO2 AND CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FIX
CAGE:53798
CAGE:53798
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTOXYETHANOL
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: <3%
Other REC Limits:N/K
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
Ingred Name:DIETHYLENE GLYCOL MONOETHYL ETHER
CAS:111-90-0
RTECS #:KK8750000
Fraction by Wt: <3%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN ABSORPTION OF 2-BUTOXYETHANOL MAY
CAUSE BLOOD ABNORMALITIES.NIOSH STUDIES INDICATE THAT
2-BUTOXYETHANOL HAS CAUSED REPRODUCTIVE DISORDERS IN LABORATORY
ANIMALS (RATS/MICE) AND MAY HAVE THE POTENT IAL FOR CAUSING SIMILAR
DISORDERS IN HUMANS .
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:IRRITATION.SKIN:IRRITATION.INGEST:HARMFUL
IF SWALLOWED.NOTE TO PHYSICIAN:PROBABLY MUSCOSAL DAMAGE MAY
CONTRAINDICATE THE USE OF GASTRIC LAVAGE.MEASURES AGAINST
CIRCULATORY SHOCK,RESPIRATORY DISTR ESS OR CONVULSIONS MAY BE
NEEDED.INHAL:N/K (FP N/ORNL ).
Medical Cond Aggravated by Exposure:N/K
======================= First Aid Measures =======================
First Aid:EYES:FLUSH EYES IMMEDIATELY WITH PLENTY OF COOL WATER FOR AT
LEAST 15 MINUTES.IF IRRITATION PERSISTS,CONTACT A
PHYSICIAN.SKIN:FLUSH WITH WATER FOR AT LEAST 15 MINUTES.IF
IRRITATION PERSISTS,CONTACT A PHYSICIAN.INGEST:DRINK MILK,EGG
WHITES OR GELATIN SOLUTION.IF THESE ARE NOT AVAILABLE,DRINK LARGE
QUANTITIES OF WATER.CALL A PHYSICIAN IMMEDIATELY.INHAL:REMOVE
PERSON TO FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point:SEE SUPP DATA
Lower Limits:N/K
Upper Limits:N/K
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .KEEP CANS COOL.USE SHIELDING TO PROTECT
PERSONNEL FROM VENTING,RUPTURING OR BURSTING CANS.
Unusual Fire/Explosion Hazard:EXPOSURE TO TEMPERATURE ABOVE 120F,48.89C
MAY CAUSE CANS TO VENT,RUPTURE OR BURST.WHEN FIX IS BURNED,CARBON
MONOXIDE AND CARBON DIOXIDE MAY BE FORMED.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH WITH WATER.ABSORB RINSE WATER IN
COMMERCIAL OIL ABSORBENT,SAND OR VERMICULITE.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:WARNING.CONTENTS UNDER PRESSURE.DO NOT
STORE NEAR HEAT OR PUNCTURE OR INCINERATE CONTAINERS.KEEP OUT OF
THE REACH OF CHILDREN.
Other Precautions:READ & FOLLOW ALL LABEL DIRECTIONS & PRECAUTIONS
BEFORE USING.DO NOT CONTAMINATE WATER,FOOD OR FEED BY STORAGE OR
DISPOSAL.FOR INDUSTRIAL AND INSTITUTIONAL USE ONLY.NOT FOR
HOUSEHOLD USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Other Protective Equipment:N/K
Work Hygienic Practices:DO NOT CONTAMINATE WATER,FOOD OR FEED BY
STORAGE OR DISPOSAL.
Supplemental Safety and Health
FL PT:PRODUCT IS WATER-BASED.NO FLAME EXTENSION.% VOLAT BY WT:>90.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/K
Vapor Density:N/K
Evaporation Rate & Reference:N/K
Solubility in Water:COMPLETE
Appearance and Odor:A FOAMING AEROSOL WITH A MINTY ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS AND STRONG CAUSTICS.
Stability Condition to Avoid:EXPOSURE TO TEMPERATURES ABOVE
120F,48.89C.
Hazardous Decomposition Products:BURNING FIX MAY RESULT IN THE
FORMATION OF CARBON MONOXIDE OR CARBON DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .OPEN DUMPING IS PROHIBITED.DO
NOT PUNCTURE,INCINERATE OR REUSE CANS.WRAP CANS AND PUT IN TRASH
COLLECTION.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LD-4, LEAK DETECT COMPOUND
Preparer's Name:BOB E FLYNT
CAGE:55208
Contract Num:SP0450-00-M-D528
CAGE:55208
============= Composition/Information on Ingredients =============
Ingred Name:TALC (NON-ASBESTOS FORM)
CAS:14807-96-6
RTECS #:MW2700000
= Wt:99.
Other REC Limits:NOT PROVIDED.
OSHA PEL:20 PPCF
ACGIH TLV:2 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT PROVIDED.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EFFECTS OF EXPOSURE: ACUTE:
INHALATION: IRRITATING TO LUNGS. SKIN: MAY TEMPORARILY STAIN SKIN
PINK. SKIN ABSORPTION: USE METHOD PRECLUDES POSSIBILITY OF SKIN
ABSORPTION HAZARD. EYE: IRRITATING TO EYES . CHRONIC: INHALATION:
PROLONGED EXPOSURE MAY LEAD TO FIBROTIC PNEUMOCONIOSIS OR FIBROSIS.
SKIN: NO CUMULATIVE EFFECTS. EYE: NO CHRONIC EFFECTS EXPECTED.
Explanation of Carcinogenicity:SUSPECTED CARCINOGEN BY ANIMAL STUDIES.
Effects of Overexposure:NOT PROVIDED.
Medical Cond Aggravated by Exposure:NOT PROVIDED.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN: WASH
WITH SOAP AND WATER. INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN
IF NEEDED. INGESTION: DO NOT INDUCE VOMITING. CONSULT PHYSICIAN
IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:NA
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:WATER.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP SPILLS AND CONTAINERIZE.
Neutralizing Agent:NOT RELEVANT.
======================Handling and Storage ======================
Handling and Storage Precautions:NOT PROVIDED.
Other Precautions:NOT PROVIDED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:OSHA/NIOSH APPROVED RESPIRATORY PROTECTION.
Ventilation:100 FEET PER MINUTE
Other Protective Equipment:NONE
Work Hygienic Practices:AVOID SKIN CONTACT, WASH WITH SOAP AND WATER
AFTER USE.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NOT RELEVANT.
Boiling Pt:B.P. Text:NONE
Melt/Freeze Pt:M.P/F.P Text:NOT AVAILABLE.
Decomp Temp:Decomp Text:NOT PROVIDED.
Vapor Pres:10MMHG @20C
Spec Gravity:0.6
pH:NOT RELEVANT.
Viscosity:NOT RELEVANT.
Evaporation Rate & Reference:NON-VOLATILE.
Solubility in Water:INSOLUBLE.
Appearance and Odor:PINK POWDER
Percent Volatiles by Volume:0
Corrosion Rate:NOT PROVIDED.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:NOT PROVIDED.
Hazardous Decomposition Products:NITROGEN OXIDES MAY BE PRODUCED DURING
COMBUSTION.
=================== Toxicological Information===================
Toxicological Information:NOT PROVIDED.
===================== Ecological Information =====================
Ecological:NOT PROVIDED.
==================== Disposal Considerations ====================
Waste Disposal Methods:AS IS THIS PRODUCT IS NOT CONSIDERED A HAZARDOUS
WASTE BY US EPA GUIDELINES. CONSULT FEDERAL, STATE AND LOCAL
REGULATORY AGENCIES FOR PROPER DISPOSAL.
=================== MSDS Transport Information ===================
Transport Information:NOT REGULATED FOR TRANSPORTATION.
===================== Regulatory Information =====================
SARA Title III Information:NOT PROVIDED.
Federal Regulatory Information:ALL MATERIALS USED IN THE MANUFACTURING
HAVE BEEN CERTIFIED BY THEIR MANUFACTURER AS BEING ON OR EXEMPT
FROM THE CURRENT TSCA INVENTORY.
State Regulatory Information:NOT PROVIDED.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HEXANE, HX0298
CAGE:IO744
CAGE:0SK29
CAGE:IO744
============= Composition/Information on Ingredients =============
Ingred Name:HEXANE; (N-HEXANE)
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: 85-90%
OSHA PEL:500 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CYCLOPENTANE, METHYL-; (METHYLCYCLOPENTANE)
CAS:96-37-7
RTECS #:GY4640000
Fraction by Wt: 5-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:METHYLPENTANES
Fraction by Wt: 0-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BENZENE (MAY CONTAIN TRACE LEVELS OF BENZENE)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: 0.0002%
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL, RAT) 28710 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TOXIC BY INGESTION AND INHALATION.
VAPOR INHALATION CAUSES IRRITATION OF NASAL AND RESPIRATORY
PASSAGES, HEADACHE, DIZZINESS, NAUSEA, CENTRAL NERVOUS SYSTEM
DEPRESSION. MAY CAUSE IRRITATION ON CONTACT WITH SKIN OR EYES. MAY
CAUSE DAMAGE TOKIDNEYS. CHRONIC OVEREXPOSURE CAN CAUSE SEVERE NERVE
DAMAGE. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: TESTS ON LAB ANIMALS INDICATE
MATERIAL MAY PRODUCE ADVERSE MUTAGENIC AND REPRODUCTIVE EFFECTS.
Medical Cond Aggravated by Exposure:KIDNEY, RESPIRATORY AND CNS
CONDITIONS.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ASSISTANCE FOR ALL CASES OF OVEREXPOSURE. SKIN:
WASH THOROUGHLY WITH SOAP AND WATER. EYES: IMMEDIATELY FLUSH
THOROUGHLY WITH WATER FOR AT LEAST 15 MINUTES. INHALATION: REMOVE
TO FRESH AIR; GIVE ARTIFICIAL RESPIRATION IF BREATHING HAS
STOPPED. INGESTION: DO NOT INDUCE VOMITING; GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:-7F,-22C
Lower Limits:1.2%
Upper Limits:7.5%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:DANGEROUS FIRE AND EXPLOSION HAZARD.
VAPOR CAN TRAVEL DISTANCES TO IGNITION SOURCE AND FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE SPILL, TAKE UP WITH ABSORBENT AND
CONTAINERIZE FOR PROPER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED. STORE IN COOL
AREA AWAY FROM IGNITION SOURCES & OXIDIZERS. DO NOT BREATHE VAPOR.
DO NOT GET IN EYES, ON SKIN OR ON CLOTHING.
Other Precautions:ELECTRICALLY GROUND ALL EQUIPMENT WHEN HANDLING THIS
PRODUCT. RETAINED RESIDUE MAY MAKE EMPTY CONTAINERS HAZARDOUS; USE
CAUTION!
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR SHOULD BE WORN IN
THE ABSENCE OF ADEQUATE VENTILATION.
Ventilation:MATERIAL SHOULD BE HANDLED OR TRANSFERRED IN AN APPROVED
FUME HOOD OR WITH ADEQUATE VENTILATION.
Other Protective Equipment:EYE WASH AND SAFETY EQUIPMENT SHOULD BE
READILY AVAILABLE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:149F,65C
Melt/Freeze Pt:M.P/F.P Text:-139F,-95C
Vapor Pres:125 @ 20C
Vapor Density:3
Spec Gravity:0.6603 (H*2O=1)
Evaporation Rate & Reference:9 (BUAC=1)
Solubility in Water:SLIGHT
Appearance and Odor:CLEAR, COLORLESS LIQUID; CHARACTERISTIC ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS.
Stability Condition to Avoid:HEAT; CONTACT WITH IGNITION SOURCES.
Hazardous Decomposition Products:CO*X.
==================== Disposal Considerations ====================
Waste Disposal Methods:TO BE PERFORMED IN COMPLIANCE WITH ALL CURRENT
LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: FAST DRY SELF VULCANIZING CEMENT, 98-855
Cage: 17124
Box: H
=======================================================
Contractor Summary
=======================================================
Cage: 17124
Box: H
=======================================================
Ingredients
=======================================================
Cas: 142-82-5
RTECS #: MI7700000
% Wt: >0.1
OSHA PEL: 500 PPM
ACGIH TLV: 400 PPM/500STEL
------------------------------
Cas: 67-64-1
RTECS #: AL3150000
% Wt: 18-20
OSHA PEL: 1000 PPM
ACGIH TLV: 750PPM/1000STEL
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 35884-05-0
COMPLES)
% Wt: 1-2
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
PROPERLY COOLED, IT MAY EXPLODE IN HEAT OF FIRE.
-----------------------------
OF NERV SYS DEPRESS (E.G., HDCH, DROW, DIZZ,
-----------------------------
SWALLOWING/VOMIT & CAUSE LUNG INFLAM & DMG.
-----------------------------
W/PERM BRAIN & NERV SYS DMG (SOMETIMES
-----------------------------
DELIB CONC & INHAL PROD MAY BE HARMFUL/FATAL.
-----------------------------
HIGH CONCENTRATIONS OF THIS MATERIAL.
-----------------------------
FRESH AIR. IF SYMPS PERSIST, SEEK IMMED MED
-----------------------------
DEVELOP, OXYG SHOULD BE ADMIN BY QUALIFIED
-----------------------------
VOMIT/GIVE ANYTHING BY MOUTH BECAUSE MATL CAN
-----------------------------
SIDE W/HEAD DOWN. IF POSS, DO NOT LEAVE
-----------------------------
OF MATL (E.G. IN ENCLSD SPACES/WITH
-----------------------------
MATL. OTHER DRUGS W/LESS ARRHYTHMOGENIC
-----------------------------
OBSERVE FOR DEVELOPMENT OF CARDIAC ARRHYTHMIAS.
-----------------------------
ENTERING SEWERS, STORM DRAINS, OTHER UNAUTH
-----------------------------
SPILL FOR LATER RECOVERY/DISP. MATL MAY
-----------------------------
DISP REQS. NOTIFY FIRE AUTHS & APPROP
-----------------------------
-----------------------------
SHOULD MEET OSHA STDS & APPROP FIRE CODES.
-----------------------------
DANGEROUS. DO NOT PRESS, CUT, WELD, BRAZE, SOLDER,
-----------------------------
SOURCES; THEY MAY EXPLODE & CAUSE INJURY/DEATH.
-----------------------------
SYSTEMS SAFE FOR SUCH LOCATIONS MAY BE USED.
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYE:MATL IS SEV IRRIT. DIRECT CONT W/LIQ/EXPOS TO
VAPS/MISTS MAY CAUSE STINGING, TEARING, REDNESS, SWELL & BLURRED VISION.
SKIN:MATL MAY CAUSE IRRIT. PRLNGD/RPTD CONT MAY CAUSE REDNESS, BURNING &
DRYI NG & CRACKING. THERE IS INSUFFICIENT INFO AVAIL ON MATL TO PREDICT
EFTS FROM ABSORP. HOWEVER, STUDIES (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZS:BY OTHER EXPOS RTES SUGGESTS LOW
DEGREE OF HAZ BY ABSORP. INHAL:WHILE MATL HAS LOW DEGREE OF TOX, BRTHG HIGH
CONCS OF VAPS/MISTS MAY CAUSE IRRIT OF NOSE & THROAT & SIGNS OF NERV
SYS DEPRESS (E.G., HDCH, DROW, DIZZ, LOSS OF COORD & FATG). INGEST:WHILE
MATL HAS LOW DEGREE OF TOX, INGEST OF EXCESSIVE
Medical Cond Aggravated By Exposure: PERSONS W/PRE-EXISTING SKIN DISORDERS MAY
BE MORE SUSCEPTIBLE TO EFTS OF MATL. RESP SYMPS ASSOC W/PRE-EXISTING LUNG
DISORDERS (E.G., ASTHMA-LIKE CNDTNS) MAY BE AGGRAVATED. HEART DISORDERS MAY
First Aid: EYE:IMMED MOVE INTO FRESH AIR. IF IRRIT/REDNESS DEVELOPS, FLUSH
W/CLEAN WATER FOR @ LST 15 MIN & SEEK IMMED MED ATTN. FOR DIRECT CONT,
IMMED HOLD LIDS APART & FLUSH AFFECTED EYE(S) W/CLEAN WATER FOR @ LST 20
MIN. SEEK IMMED MED ATTN. SKIN:REMOVE CONTAM SHOES & CLTHG & CLEANSE
AFFECTED AREA(S) THORO BY WASHING W/MILD SOAP & WATER. IF IRRIT/REDNESS
DEVELOPS & PERSISTS, SEEK MED ATTN.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: EXTREMELY FLAM. KEEP ALL SOURCES OF IGNIT & HOT
METAL SURFS AWAY FROM SPILL/RELS. STAY UPWIND & AWAY FROM SPILL/RELS.
ISOLATE HAZ AREA & LIM ENTRY TO EMER CREW. STOP SPILL/RELS IF IT CAN BE
DONE W/OUT RISK. WEAR APPROP PROT EQUIP INCLUDING
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH LOCAL, COUNTY, STATE AND
FEDERAL REGULATIONS. EPA REPORTABLE QUANTITY:ACETONE:5,000 LBS EQUIVALENT TO
25,000 LBS OF THIS PRODUCT. CNTNRS SHOULD BE DISPD OF IN AN ENVIRONM ENTALLY
SAFE MANNER AND IN ACCORD W/GOVT REGS.
Handling And Storage Precautions: KEEP CNTNR(S) TIGHTLY CLSD. USE & STORE
MATL IN COOL, DRY, WELL VENTD AREAS AWAY FROM HEAT, DIRECT SUNLIGHT, HOT
METAL SURFS & ALL IGNIT SOURCES.
Other Precautions: POST AREA "NO SMKING/OPEN FLAME". BOND & GROUND ALL
EQUIP WHEN TRANSFERRING FROM ONE VESSEL TO ANOTHER. STORE ONLY IN APPRVD
CNTNRS. KEEP AWAY FROM INCOMPAT MATLS. PROT CNTNR(S) AGAINST PHYSICAL DMG.
USE OF EXPLO-PROOF EQUIP IS REC
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: -4F,-20C
Lower Limits: 1.0%
Upper Limits: 13.2%
Extinguishing Media: DRY CHEMICAL, CARBON DIOXIDE, HALON, POLAR OR ALCOHOL
FOAM, OR WATER SPRAY IS RECOMMENDED. WATER MAY BE INEFFECTIVE.
Fire Fighting Procedures: WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP (FP N).
STOP SPILL/RELS IF IT CAN BE DONE W/OUT RISK. MOVE UNDMGD CNTNRS FROM FIRE
AREA IF IT CAN BE DONE W/OUT(SUPDAT)
Unusual Fire/Explosion Hazard: MATL IS EXTREMELY FLAM & MAY BE IGNITED BY
HEAT, SPKS, FLAME/OTHER IGNIT SOURCES (E.G. STATIC ELEC, PILOT LIGHTS,
MECH/ELEC EQUIP). VAPS MAY TRAVEL (SUPP DATA)
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE OF RESPIRATORY PROTECTION IS ADVISED WHEN
CONCENTRATIONS EXCEED THE ESTABLISHED EXPOSURE LIMITS. DEPENDING ON AIRBORNE
CONCENTRATION, USE A RESPIRATOR OR GAS MASK WITH APPROP CARTRIDGE &
CANISTERS (NIOSH APPRVD)/SUPPLIED AIR EQUIP.
Ventilation: IF CURRENT PRACT ARE NOT ADEQ TO MAINTAIN AIRBORNE CONCS BELOW
ESTABLISHED EXPOS LIMS, ADDNL VENT/EXHST SYS MAY
Other Protective Equipment: ANSI APPROVED EMERGENCY EYE WASH AND DELUGE SHOWER
(FP N). IT IS RECOMMENDED THAT AN IMPERVIOUS APRON BE WORN.
Work Hygienic Practices: THORO CLEAN SHOES & WASH CONTAM CLTHG BEFORE REUSE.
WASH HANDS THORO AFTER HNDLG. USE GOOD PERS HYGIENE PRACTICE.
Supplemental Safety and Health: FIRE FIGHT PROC:RISK. WATER SPRAY MAY BE USEFUL
IN MIN/DISPERSING VAPS & COOLING EQUIP EXPOSED TO HEAT & FLAME. AVOID
SREADING BURNING LIQ W/WATER USED FOR COOLING PURPOSES. EXPLO
HAZS:CONSIDERABLE DI ST TO IGNIT SOURCE WHERE THEY MAY IGNITE,
FLASHBACK/EXPLODE. VAP/AIR EXPLO HAZ INDOORS/OUTDOORS OR IN SEWERS.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >133F,>56C
Vapor Pres: 186
Vapor Density: HVR/AIR
Spec Gravity: 0.72
Evaporation Rate & Reference: 4.50 (N-BUTYL ACETATE=1)
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume: 94-96
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: AVOID ALL POSSIBLE SOURCES OF IGNITION (SEE FIRE
AND EXPLOSION HAZARD DATA AND OTHER PRECAUTIONS).
Materials To Avoid: THIS PRODUCT IS INCOMPATIBLE WITH STRONG ACIDS, BASES,
OXIDIZING AGENTS AND SELECTED AMINES.
Hazardous Decomposition Products: COMBUST MAY YIELD CARBON MONOXIDE AND/OR
DIOXIDE. DO NOT BREATHE SMOKE OR FUMES. WEAR APPROPRIATE PROTECTIVE EQUPMENT.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: FAST DRY SELF VULCANIZING CEMENT, 98-855
Cage: 17124
Company Name: PATCH RUBBER CO
Street: BECKER INDUSTRIAL PARK
PO Box: H
Zipcode: 27870
Label Required IND: Y
Date Of Label Review: 10/23/1996
Status Code: C
Label Date: 10/23/1996
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Severe
Contact Hazard: Severe
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: EXTREMELY FLAMMABLE. ACUTE:EYE:SEVERE IRRITANT;
STINGING, TEARING, REDNESS, SWELLING, BLURRED VISION. SKIN:IRRITANT; REDNESS,
BURNING AND DRYING, CRACKING. INHALATION:IRRITATION, CENTRAL NERVOUS SYSTE M
DEPRESSION (HEADACHE, DROWSINESS, DIZZINESS, LOSS OF COORDINATION AND
FATIGUE). INGESTION:IRRITATION, DIARRHEA, CENTRAL NERVOUS SYSTEM DEPRESSION.
ASPIRATION HAZARD. CHRONIC:MAY CAUSE PERMANENT BRAI N AND NERVOUS SYSTEM
DAMAGE. MISUSE MAY BE FATAL OR HARMFUL.
=======================================================
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: CHARGER GRAY, PFH604S8055
Cage: 070V3
=======================================================
Contractor Summary
=======================================================
Cage: 070V3
=======================================================
Ingredients
=======================================================
Cas: 7727-43-7
RTECS #: CR0600000
% Wt: 10-30
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST
------------------------------
Cas: 2451-62-9
RTECS #: XZ1994900
(1,3,5-TRIGLYCIDYL ISOCYANURATE)
% Wt: 3-7
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 13463-67-7
RTECS #: XR2275000
% Wt: 1-5
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST
------------------------------
Cas: 51274-00-1
% Wt: <1.5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
% Wt: 100
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
TITANIUM DIOXIDE: LAB STUDIES SHOW THAT INHAL
-----------------------------
CANCEROUS TUMORS IN RATS. THIS RESPONSE
-----------------------------
OVERWHELMING NORMAL LUNG CLEARANCE MECHANISMS.
-----------------------------
OBSERVED.
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: 1,3,5-TRIGLYCIDYL ISOCYANURATE: INGEST: MOD TOXIC.
SYMPS ARE NOT FULLY KNOWN, MAY INCL LOSS OF APPETITE & NOSE BLEEDING.
INHAL: IRRIT TO UPPER RESP TRACT. MAY CAUSE NOSEBLEEDS. EYE CONT: IRRIT.
SKIN CONT: IRRIT. CAN BE ABSORBED THRUSKIN IN HARMFUL AMTS. EFTS SIMILAR TO
INGEST. BARIUM SULFATE: (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: INHAL OF DUSTS CNTNG BARIUM
SULFATE MAY BE IRRIT TO RESP TRACT. CONT W/EYES MAY ALSO CAUSE IRRIT.
TITANIUM DIOXIDE: INGEST: LOW ORAL TOX. NO TOXIC EFTS DUE TO INGEST ARE
DESCRIBED IN LITERAT URE. INHAL: IRRIT TO UPPER RESP TRACT. EYE CONT: IRRIT.
CHRONIC: 1,3,5-TRIGLYCIDYL ISOCYANURATE: IRRIT OF EYES, (SUPDAT)
Medical Cond Aggravated By Exposure: 1,3,5-TRIGLYCIDYL ISOCYANURATE:
RESPIRATORY ILLNESS & DERMATITIS MAY BE AGGRAVATED BY EXCESSIVE EXPOSURE.
First Aid: EYE CONT: FLUSH W/COOL WATER FOR @ LST 15 MINS, OCCASNLY LIFTING
LIDS TO ENSURE THOROUGH RINSING. SEEK MED ASSISTANCE. SKIN CONT: WASH
THOROUGHLY W/SOAP & WATER. INHAL: REMOVE FROM AREA TO FRESH AIR.INGEST:
DRINK 1 OR 2 GLASSES OF WATER &INDUCE VOMITING BY PLACING FINGER AT BACK
OF THROAT. SEEK MEDICAL ASSISTANCE.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SWEEP UP CAREFULLY OR USE EXPLOSION-PROOF VACUUM
CLEANER, THEN DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: MANAGE OR DISPOSE IN ACCORDANCE WTIH LOCAL, STATE AND
FEDERAL REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.
Handling And Storage Precautions: KEEP CONTAINERS SEALED AND AVOID STATIC
ELECTRICITY DISCHARGES. KEEP ALL EQUIPMENT CLEAN & PROPERLY GROUNDED TO
AVOID STATIC ELECTRICITY DISCHARGE.
Other Precautions: KEEP WORK AREAS FREE OF DUST. AVOID EXCESSIVE SKIN CONTACT.
DO NOT INGEST OR INHALE. KEEP OUT OF REACH OF CHILDREN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: FOAM, CO*2, DRY CHEMICAL, WATER FOG, DRY SAND.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE A PROPERLY FITTED NIOSH APPROVED MECHANICAL
RESPIRATOR OR MASK TO AVOID BREATHING DUST. CAREFULLY FOLLOW RESPIRATOR
MANUFACTURER'S INSTRUCTIONS FOR USE.
Ventilation: PROVIDE SUFFICIENT VENT IN VOL & PATTERN TO KEEP AIR CONTAM
CONC BELOW APPLIC OSHA PERMISSIBLE EXPOS LEVELS
Other Protective Equipment: ANSI APPRVD EYE WASH & DELUGE SHOWER (FP N).
PROTECTIVE OVERALLS RECOMMENDED.
Work Hygienic Practices: REMOVE AND WASH SOILED CLOTHING.
Supplemental Safety and Health: EFTS OF OVEREXP: SKIN & RESP TRACT; LOSS OF
APPETITE, MAY CAUSE NOSEBLEEDS; TOXIC BY INGEST & IF ABSORBED THRU SKIN.
PRLNGD/RPTD CONT MAY CAUSE SKIN SENSITIZ. ANIMAL STUDIES SHOW THAT OVEREXP
CAN RSLT IN TOXIC EFTS TO TESTES, POSS EFTS ON LIVER & LUNG, & POSS
ADVERSE MALE REPROD EFTS. BARIUM SULFATE: PRLNGD
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 1.477
Evaporation Rate & Reference: NOT KNOWN
Solubility in Water: NOT KNOWN
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products: FUMES MAY CONTAIN CO, CO*2, NO*2 OR OTHER
NITROGEN COMPOUNDS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: VOLATILE ORGANIC COMPOUND: 0
=======================================================
HAZCOM Label
=======================================================
Product ID: CHARGER GRAY, PFH604S8055
Cage: 070V3
Company Name: DUPONT POWDER COATINGS
Street: 9800 GENARD RD
Zipcode: 77041-7624
Label Required IND: Y
Date Of Label Review: 04/08/1998
Status Code: C
Label Date: 04/08/1998
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: 1,3,5-TRIGLYCIDYL ISOCYANURATE: INGEST: MODERATE
TOXICITY. POSSIBLE LOSS OF APPETITE & NOSE BLEEDING. INHAL: IRRITATION.
NOSEBLEEDS. EYE & SKIN CONT: IRRITATION. CAN BE ABSORBED THRU SKIN IN HA
RMFUL AMOUNTS. BARIUM SULFATE: IRRITATION TO RESPIRATORY TRACT. EYE CONT:
IRRITATION. TITANIUM DIOXIDE: INGEST: LOW ORAL TOX. INHAL: IRRITATION. EYE:
IRRITATION. CHRONIC: 1,3,5-TRIGLYCIDYL ISOCYANURAT E: IRRITATION OF EYES,
SKIN & RESP TRACT; LOSS OF APPETITE, NOSEBLEEDS; TOXIC BY INGEST & IF
ABSORBED THRU SKIN. SKIN SENSITIZATION. REPRODUCTIVE EFFECTS. LIVER AND LUNG
DAMAGE. BARIUM SULFATE: BARITO SIS. TITANIUM DIOXIDE - POSSIBLE CANCEROUS
TUMORS.
=======================================================
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: RPD RAPID PROCESS DEVELOPER
Cage: 0F0U5
=======================================================
Contractor Summary
=======================================================
Cage: 76381
Cage: 0F0U5
Country: UK
=======================================================
Ingredients
=======================================================
Cas: 7732-18-5
RTECS #: ZC0110000
% Wt: 50-60
------------------------------
Cas: 16731-55-8
RTECS #: TT4920000
% Wt: 10-15
------------------------------
Cas: 1310-58-3
RTECS #: TT2100000
% Wt: 10-15
OSHA PEL: 2 MG/M3, C
ACGIH TLV: 2 MG/M3, C
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 123-31-9
RTECS #: MX3500000
% Wt: 5-10
OSHA PEL: 2 MG/M3
ACGIH TLV: 2 MG/M3
EPA Rpt Qty: 1 LB
DOT Rpt Qty: 1 LB
------------------------------
Cas: 111-42-2
RTECS #: KL2975000
% Wt: 5-10
OSHA PEL: 3 PPM
ACGIH TLV: 3 PPM
EPA Rpt Qty: 1 LB
DOT Rpt Qty: 1 LB
------------------------------
Cas: 584-08-7
RTECS #: TS7750000
% Wt: 1-5
------------------------------
Cas: 50-21-5
RTECS #: OD2800000
% Wt: 1-5
------------------------------
Cas: 67-43-6
RTECS #: MB8205000
(DIETHYLENETRIAMINEPENTAACITIC ACID)
% Wt: 1-5
------------------------------
Cas: 7758-02-3
RTECS #: TS7650000
% Wt: 1-5
------------------------------
Cas: 141-43-5
RTECS #: KJ5775000
% Wt: <0.1
OSHA PEL: 3 PPM;6 PPM STEL
ACGIH TLV: 3 PPM;6 PPM STEL
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYE/SKIN:MAY CAUSE IRRIT. INHAL:MAY CAUSE SLIGHT RESP SYS
IRRIT. SULFITES CAN CAUSE ASTHMATIC LIKE REACTIONS IN SUSCEPTIBLE
INDIVIDUALS. INGEST:MAY CAUSE SEV DIGEST TRACT IRRIT & TISS DAM DUE TO
ALKAL INITY. HYDROQUINONE CAN CAUSE DIZZ, NAUS, MENTAL CONFUSION & DEATH.
SULFITES CAN CAUSE ASTHMATIC LIKE (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ: REACTIONS IN SUSCEPTIBLE
INDIVIDUALS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYE: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.
CALL MD. SKIN: WASH WITH SOAP AND WATER. INHAL: IF IRRITATION OR OTHER
SYMPTOMS OCCUR, PROVIDE FRESH AIR. CALL MD. INGEST: DO NOT I NDUCE VOMITING.
GIVE MILK OR WATER. CALL MD.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: OBSERVE PRECAUTIONS IN OTHER SECTIONS OF THIS MSDS.
FLUSH SMALL RESIDUES TO SEWER. DIKE AND COLLECT LARGE SPILLS. WASH SPILL AREA
WITH WATER TO REMOVE RESIDUE.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: WASTE CAN USUALLY BE DISCHARGED TO A WASTE WATER
TREATMENT SYS AFTER MIXING W/OTHER FACILITY WASTE/WEAK ACID TO LOWER PH TO
LOC LIMS. SINCE REGS VARY, CONSULT APPLIC REGS/AUTHORITIES BEFORE DISP.DISPO
SE OF I/A/W FED, STATE AND LOCAL REGS (FP N).
Handling And Storage Precautions: KEEP CONTAINER CLOSED WHEN NOT IN USE. KEEP
OUT OF REACH OF CHILDREN.
Other Precautions: AVOID EYE AND SKIN CONTACT. AVOID PROLONGED BREATHING OF
VAPOR. DO NOT TAKE INTERNALLY.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N).
Ventilation: NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment: NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: PH: 11-11.5.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: C2
B.P. Text: 223F,106C
Vapor Pres: 17.5 @ 68F
Spec Gravity: 1.290 G/CC
PH: SUPDAT
Evaporation Rate & Reference: >1 (WATER=1)
Solubility in Water: COMPLETE
Appearance and Odor: CLEAR, SLIGHTLY YELLOW LIQUID.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: ACIDS.
Hazardous Decomposition Products: NOT DETERMINED.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 39851
Product ID: RPD RAPID PROCESS DEVELOPER
Review Date: 04/06/1993
Multiple KIT Number: 0
Review IND: Y
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: DWE
Symbols: G
DOT Proper Shipping Name: CORROSIVE LIQUIDS, N.O.S.
Hazard Class: 8
UN ID Num: UN1760
DOT Packaging Group: II
Label: CORROSIVE
Special Provision: B2,T14
Packaging Exception: 154
Non Bulk Pack: 202
Bulk Pack: 242
Max Qty Pass: 1 L
Max Qty Cargo: 30 L
Vessel Stow Req: B
Water/Ship/Other Req: 40
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ESH
IMO Proper Shipping Name: CORROSIVE LIQUID, N.O.S. o
IMDG Page Number: 8147
UN Number: 1760
UN Hazard Class: 8
IMO Packaging Group: I/II/III
Subsidiary Risk Label: -
EMS Number: 8-15
MED First Aid Guide NUM: 760
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: HKR
IATA UN ID Num: 1760
IATA Proper Shipping Name: CORROSIVE LIQUID, N.O.S. *
IATA UN Class: 8
IATA Label: CORROSIVE
UN Packing Group: II
Packing Note Passenger: 808
Max Quant Pass: 1L
Max Quant Cargo: 30L
Packaging Note Cargo: 812
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: HKR
AFI Symbols: *
AFI Proper Shipping Name: CORROSIVE LIQUID, N.O.S.
AFI Hazard Class: 8
AFI UN ID NUM: UN1760
AFI Packing Group: II
Special Provisions: P4
Back Pack Reference: A12.3
=======================================================
HAZCOM Label
=======================================================
Product ID: RPD RAPID PROCESS DEVELOPER
Cage: 0F0U5
Company Name: PACEBROOK LTD
Street: 15 GOSDITCH ST
Zipcode: 00000
Country: UK
Label Required IND: Y
Date Of Label Review: 10/09/1992
Status Code: C
Label Date: 10/09/1992
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: SWALLOWING MAY CAUSE SEVERE DIGESTIVE TRACT
IRRITATION AND TISSUE DAMAGE DUE TO ALKALINITY. CAN CAUSE DIZZINESS, NAUSEA,
MENTAL CONFUSION AND DEATH. INHALATION MAY CAUSE SLIGHT RESPIRATORY SYST EM
IRRITATION. MAY CAUSE EYE AND SKIN IRRITATION. AVOID EYE AND SKIN CONTACT.
AVOID PROLONGED BREATHING OF VAPOR. DO NOT SWALLOW. CHRONIC: NONE LISTED BY
MFR.
=======================================================
| 1 | eyes_protection_mandatory |
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.