text
stringlengths 595
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:P29-212 VMK 68N PAINT ON OPAQUE, 250 GRAMS
CAGE:67251
CAGE:67251
============= Composition/Information on Ingredients =============
Ingred Name:NICKEL (SOLUBLE)
INTENDED CHANGE (IC)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: <5%
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/CUM
ACGIH TLV:0.05 MG/CUM IC (A1)
Ingred Name:VANADIUM
CAS:1314-62-1
RTECS #:YW1355000
Fraction by Wt: <5%
OSHA PEL:C,0.5 MG/M3
ACGIH TLV:0.05 MG/M3RDUST;9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ZINC OXIDE
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: <5%
OSHA PEL:15MG/M3 TDUST/5 FUME
ACGIH TLV:10MG/M3 TDUST; 9293
Ingred Name:ZIRCONIUM
CAS:7440-67-7
RTECS #:ZH7070000
Fraction by Wt: <5%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:ALUMINUM OXIDE, BAUXITE, ALUMINA, DIALUMINUM TRIOXIDE
CAS:1344-28-1
RTECS #:BD1200000
Fraction by Wt: <5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:BARIUM (SOLUBLE COMPOUNDS)
CAS:7440-39-3
RTECS #:CQ8370000
Fraction by Wt: <5%
OSHA PEL:0.5 MG/CUM
ACGIH TLV:0.5 MG/CUM
Ingred Name:BORON OXIDE, TRIOXIDE
CAS:1303-86-2
RTECS #:ED7900000
Fraction by Wt: <5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9293
Ingred Name:CALCIUM OXIDE; LIME
CAS:1305-78-8
RTECS #:EW3100000
Fraction by Wt: <5%
OSHA PEL:5 MG/CUM
ACGIH TLV:2 MG/CUM
Ingred Name:MAGNESIUM OXIDE, MAGNESIA
CAS:1309-48-4
RTECS #:OM3850000
Fraction by Wt: <5%
OSHA PEL:15 MG/M3 PARTICULATE
ACGIH TLV:10 MG/M3;TDUST; 9293
Ingred Name:SILICA, CRYSTALLINE - FUSED
CAS:60676-86-0
RTECS #:VV7328000
Fraction by Wt: <5%
Other REC Limits:30 MG/CUM TOTAL DUST
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:TIN (AS SN)
CAS:7440-31-5
RTECS #:XP7320000
Fraction by Wt: <5%
OSHA PEL:2.0 MG/CUM
ACGIH TLV:2.0 MG/CUM
Ingred Name:TITANIUM DIOXIDE, TITANIUM(IV) OXIDE, TIO2
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: <5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:CHROMIUM METAL, CHROMIUM, CHROME (SUSPECTED A1 HUMAN
CARCINOGEN BY IARC, NTP & ACGIH)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: <5%
OSHA PEL:1 MG/CUM
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:COBALT
CAS:7440-48-4
RTECS #:GF8750000
Fraction by Wt: <5%
Other REC Limits:0.05 PPM
OSHA PEL:0.1 MG/M3;AS CO
ACGIH TLV:0.05 MG/M3;DUST 9293
Ingred Name:RED IRON OXIDE/IRON (III) OXIDE/FERRIC OXIDE/YELLOW FERRIC
OXIDE/METAL OXIDE/YELLOW IRON OXIDE/IRON OXIDE PIGMENT/IRON
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: <5%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
Ingred Name:MANGANESE, MN COMPOUNDS
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: <5%
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Explanation of Carcinogenicity:CHROMIUM IS A SUSPECTED A1 HUMAN
CARCINOGEN BY ACGIH.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP SPILLED MATERIAL.
======================Handling and Storage ======================
Other Precautions:AVOID BREATHING CERAMIC DUST. AVOID LICKING CERAMIC
APPLICATION BRUSH.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NUISANCE DUST MASK RECOMMENDED WHILE GRINDING
FIRED PORCELAIN.
Ventilation:MECHANICAL EXHAUST
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>2192F
Melt/Freeze Pt:M.P/F.P Text:1760F
Evaporation Rate & Reference:0
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE OR LIGHT PASTEL COLORED PORCELAIN POWDER W/NO
ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HYDROFLUORIC ACID
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE AS SOLID WASTE IN ACCORDANCE W/LOCAL,
STATE, & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:1020/1035/2830 DEVELOPER, 5R523
CAGE:0E6G9
CAGE:0E6G9
CAGE:26921
============= Composition/Information on Ingredients =============
Ingred Name:TONER CONSISTINGS OF INGREDIENTS 6-10
RTECS #:9999999ZZ
Ingred Name:STYRENE/ACRYLATE POLYMER
CAS:25213-39-2
Fraction by Wt: 60-65%
Ingred Name:ACRYLIC RESIN
CAS:26299-47-8
Fraction by Wt: 20-25%
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 10-15%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:PROPENE POLYMERS; (POLYOLEFIN)
CAS:9003-07-4
RTECS #:UD1842000
Fraction by Wt: <5%
Ingred Name:SILICON DIOXIDE, AMORPHOUS; (AMORPHOUS SILICA)
CAS:7631-86-9
Fraction by Wt: <1%
Ingred Name:CARRIER CONSISTINGS OF INGREDIENTS 2-4
RTECS #:9999999ZZ
Fraction by Wt: >95%
Ingred Name:IRON. PEL & TLV AS FE*2O*3
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: >70%
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:5 MG/M3 FUME
Ingred Name:ZINC. PEL & TLV AS ZINC OXIDE
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: 15-20%
OSHA PEL:5MG/M3;10 MG/M3 STEL
ACGIH TLV:5MG/M3;10 MG/M3 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:NICKEL
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 5-15%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT)>5 G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:MINIMAL RESPIRATORY TRACT IRRITATION
MAY OCCUR AS WITH EXPOSURE TO LARGE AMOUNTS OF ANY NON-TOXIC DUST.
IN XEROX SPONSORED CHRONIC INHAL STUDY IN RATS USING SPECIAL TEST
TONER, THERE WERE NO LUNG CHAN GES @ ALL IN THE LOWEST EXPOS LEVEL
(1MG/M3), MOST RELEVANT LEVEL TO POTNTL HUMAN EXPOS. VERY SLIGHT
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NICKEL IARC GROUP 2B; NTP GROUP 2.
Effects of Overexposure:HLTH HAZ:DEGREE OF FIBROSIS WAS NOTED IN 25% OF
ANIMALS @ MIDDLE EXPOS LEVEL (4MG/M3) WHILE SLIGHT DEGREE OF
FIBROSIS WAS OBSERVED @ HIGHEST EXPOS LEVEL (16 MG/M3) IN ALL
ANIMALS. FINDINGS ARE ATTRIBU TED TO "LUNG OVERLOADING", A GENERIC
RESPONSE TO EXCESSIVE AMT OF ANY DUST RETAINED IN LUNGS FOR PRLNG
(SUPP DATA)
Medical Cond Aggravated by Exposure:NONE WHEN USED AS DESCRIBED BY
PRODUCT LITERATURE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MIN. SKIN: WASH WITH
SOAP AND WATER. INHAL: REMOVE FROM EXPOSURE. INGEST: DILUTE STOMACH
CONTENTS WITH SEVERAL GLASSES OF WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:IF SPILLED, SWEEP UP OR VACUUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE.
Other Precautions:AVOID PROLONGED INHALATION OF EXCESSIVE DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN XEROX
EQUIP. USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN .
Ventilation:NONE REQUIRED WHEN USED AS INTENDED IN XEROX EQUIPMENT.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP: INTERVAL. SPECIAL TEST TONER WAS 10 TIMES MORE
RESPIRABLE THAN COMMERCIALLY AVAILABLE XEROX TONER TO COMPLY WITH
EPA TESTING PROTOCOL AND WOULD NOT FUNCTION PROPERLY IN XEROX
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:APPROX 5
Appearance and Odor:BLACK GRANULAR/FAINT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION MAY BE TOXIC.
AVOID BREATHING SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:NO SPECIFIC WASTE DISPOSAL METHOD REQUIRED.
DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE, AND LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FRICTION MATERIAL CONTAINING ASBESTOS
Preparer's Name:F. M. BOCK
CAGE:11083
CAGE:11083
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
Fraction by Wt: 10-40%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:PHENOLIC RESIN
Fraction by Wt: 15-48%
Other REC Limits:NONE SPECIFIED
Ingred Name:METAL BASE
Fraction by Wt: 60-78%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TOTAL DUST
ACGIH TLV:10 MG/M3 TOTAL DUST
Ingred Name:CARBON
RTECS #:FF5251000
Fraction by Wt: 5-30%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE-NONE UNDER NORMAL CONDITIONS OF
USE.GRINDING,SANDING OR MACHINING MAY PRODUCE DUST THAT CAN CAUSE
IRRITATION OF EYES, SKIN AND RESPIRATORY PASSAGES. CHRONIC- LONG
TERM EXPOSURE TO ASBESTOS CAN C AUSE IRREVERSIBLE ASBESTOSIS, LUNG
DISEASE, LUNG CANCER. RESIN MAY CAUSE DERMATITIS.
Explanation of Carcinogenicity:ASBESTOS IS REGULATED BY OSHA AS A
CARCINOGEN.
Effects of Overexposure:NONE UNDER NORMAL CONDITIONS OF USE. HOWEVER,
GRINDING, SANDING OR MACHINING MAY PRODUCE NUISANCE PARTICULATES
THAT CAN CAUSE IRRITATION OF EYES, SKIN AND RESPIRATORY PASSAGES.
LONG TERM EXPOSURE TO A SBESTOS CAN CAUSE IRREVERSIBLE ASBESTOSIS,
LUNG DISEASE, LUNG CANCER.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS SUCH AS DERMATITIS, LUNG DISEASE OR ANY CONDITION THAT
MAY BE AGGRAVATED BY NUISANCE DUST OR FIBERS.
======================= First Aid Measures =======================
First Aid:SHOULD NOT BE NECESSARY FROM A PROPER HANDLING. HOWEVER, SEEK
MEDICAL ATTENTION IF SYMPTOMS DEVELOP. IN CASE OF EYE IRRITATION
GENTLY RINSE WITH WATER FOR 15 MINUTES WHILE KEEPING EYELIDS OPEN.
SKIN: WASH FREQUENTLY WITH SOAP AND WATER. INHALATION: REMOVE TO
FRESH AIR. INGESTION: UNLIKELY.
===================== Fire Fighting Measures =====================
Flash Point:NON FLAMMABLE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:TOXIC DECOMPOSITION FUMES OR ASBESTOS
FIBERS MAY BE EVOLVED IN A FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:TREAT DUST AS FREE ASBESTOS. DO NOT DRY SWEEP
OR USE COMPRESSED AIR. WET METHOD SHOULD BE USED FOR EXTRACTION OF
DUST AND DEBRIS. HIGH EFFICIENCY PARTICULATE APPARATUS (HEPA)
VACUUMS SHOULD BE USED.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE- AVOID CREATING DUST BY
SANDING OR GRINDING THE PRODUCT.
Other Precautions:USE IN WELL VENTILATED AREA. AVOID BREATHING DUST OR
FIBERS. MINIMIZE CONTACT WITH SKIN. AVOID CONTACT WITH EYES. DO NOT
RAISE DUST. WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING OR
DRINKING. KEEP AWAY FROM REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED HIGH EFFICIENCY FIBERS/FUMES
RESPIRATOR WHEN AIRBORNE FIBER CONCENTRATIONS EXCEED THE PEL.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV. CHECK LOCAL REGULATIONS
FOR EMISSION STANDARDS.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER, WORK
CLOTHING AND APRON AS REQUIRED. DO NOT WEAR CONTACT LENSES
Work Hygienic Practices:DON'T TAKE PROTECTIVE GEAR/CLOTHING HOME IF
EXPOSED TO DUST. DON'T SHAKE. DON'T EAT IN AREA WHERE ASBESTOS/DUST
PRESENT.
Supplemental Safety and Health
THE MANUFACTURER STATES THAT THE FRICTION MATERIAL PRODUCT, AS SHIPPED,
IS NOT CONSIDERED HAZARDOUS, AND IS NOT REQUIRED TO HAVE LABEL OR
MSDS. BUT MACHINING, GRINDING, DRILLING AND/OR NORMAL USE MAY
CREATE ASBESTOS DUST OR AIRBORNE ASBESTOS FIBERS IN EXCESS OF OSHA
STANDARD AND SHOULD BE CONSIDERED HAZARDOUS.
================== Physical/Chemical Properties ==================
HCC:T6
Appearance and Odor:SOLID MATERIAL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
Hazardous Decomposition Products:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE SHOULD BE CONTAINED IN IMPERMEABLE BAGS,
LABELED AND DISPOSED IN ACCORDANCE WITH ALL LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:STAINLESS STEEL PUTTY(ST) HARDNER
CAGE:0RZG3
CAGE:0RZG3
============= Composition/Information on Ingredients =============
Ingred Name:TRIETHYLENE TETRAMINE
CAS:112-24-3
RTECS #:YE6650000
Fraction by Wt: 40-60%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYAMIDE OF C*18 FATTY ACID PRIMERS AND TETA
CAS:68410-23-1
Fraction by Wt: 50-70%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS 2460 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES-SEVERE IRRITATION OR BURNS.
SKIN-SEVERE IRRITATION OR BURNS. INHALATION-IRRITATION OF NOSE AND
THROAT; NAUSEA AND VOMITING IN SEVERE CASES. INGESTION-MAY CAUSE
BURNS OF MOUTH AND THROAT AND GAST ROINTESTINAL IRRITATION OR
ULCERATION.
Explanation of Carcinogenicity:INGREDIENTS LISTED: NO
Effects of Overexposure:REPEATED SKIN CONTACT OR INHALATION OF FUMES
CAN CAUSE SENSITIZATION, WITH ITCHING, RASHES, OR SWELLING OF THE
SKIN OR AN ASTHMA-LIKE RESPIRATORY REACTION ON LATER EXPOSURE TO
THE PRODUCT. REPEATED OV EREXPOSURE TO TETA CAN CAUSE LIVER AND
KIDNEY EFFECTS.
Medical Cond Aggravated by Exposure:ASTHMA, BRONCHITIS OR SKIN
IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES-IMMEDIATELY FLUSH WITH CLEAN WATER FOR AT LEAST 15 MIN.
WHILE GENTLY HOLDING EYELIDS OPEN. GET MEDICAL HELP AS SOON AS
POSSIBLE. SKIN-IMMEDIATELY REMOVE CONTAMINATED CLOTHING AND WASH
WELL WITH D OAP AND WARM WATER. SEE DOCTOR IF IRRITATION DEVELOPS.
INHALATION-REMOVE PATIENT TO FRESH AIR. GIVE OXYGEN OR CPR IF
NEEDED. INGEATION-DO NOT INDUCE VOMITING. DILUTE WITH MILK/WATER &
GET MEDICAL AID.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>200F,>93C
Extinguishing Media:WATER, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR SELF-CONTAINED
BREATHING APPARATUS AND SUFFICIENT PROTECTIVE GEAR TO PREVENT ALL
SKIN AND EYE CONTACT WITH THIS MATERIAL.
Unusual Fire/Explosion Hazard:DECOMPOSITION PRODUCES HAZARDOUS FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:PREVENT SKIN AND EYE CONTACT; REMOVE
CONTAMINATED CLOTHING AND SHOES. ABSORB SPILL ON INERT MATERIAL
SUCH AS VERMICULITE; SCRAPE UP AND TRANSFER TO IMPERVIOUS
CONTAINERS. SCRUB SPILL AREA WITH STRONG DETERGENT AND WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE WELL-CLOSED IN A COOL, DRY
PLACE. KEEP HANDS AWAY FROM EYES WHEN HANDLING, AND UNTIL HANDS ARE
WASHED AFETR USING MATERIALS.
Other Precautions:IF THIS PRODUCT IS SANDED OR MACHINED AFTER CURING,
TAKE APPROPIATE PRECAUTIONS AGAINST INHALATION OF NUISANCE
PARTICLES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NEEDED IN NORMAL USE WITH PROPER
VENTILATION. IN POORLY VENTILATED AREAS USE NIOSH-APPROVED ORGANIC
VAPOR RESPIRATOR.
Ventilation:GENERAL MECHANICAL VENTILATION IS ADEQUATE FOR OCCASIONAL
USE. FOR PROLONGED OR REPEATED USE, LOCAL EXHAUST.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING AND LAUNDER
THOROUGHLY BEFORE REUSE.
Supplemental Safety and Health
PROPER SHIPPING NAME: CORROSIVE LIQUID, N.O.S.. (CONTAINER<1 PINT ARE
ORM-D).
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>450F,>232C
Melt/Freeze Pt:M.P/F.P Text:N/D
Vapor Pres:<0.01
Vapor Density:>1
Spec Gravity:0.98
pH:10-11
Evaporation Rate & Reference:<1
Solubility in Water:30-60%
Appearance and Odor:WHITE PASTE WITH MILD AMMONIA-LIKE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS AND CHLORINATED ORGANIC COMPOUNDS.
Stability Condition to Avoid:EXTREME HEAT OR OPEN FLAMES.
Hazardous Decomposition Products:ACRIDS AND TOXIC FUMES WITH ORGANIC
AMINES, AMMONIA, OXIDES OF CARBON AND NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP OUT OF PUBLIC WATER SUPPLIES. INCINERATE IN
APPROVED FACILITY WHERE PERMITTED BY STATE AND LOCAL REGULATION.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:9305 HEAVY DUTY EPOXY ACTIVATOR PRIMER
CAGE:08882
CAGE:08882
============= Composition/Information on Ingredients =============
Ingred Name:PROPYLENE GLYCOL METHYL ETHER (1-METHOXY-2-PROPANOL)
PROPYLENE GLYCOL MONO METHYL ETHER
CAS:107-98-2
RTECS #:UB7700000
Fraction by Wt: 15%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 40%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BUTANOL, N-BUTYL ALCOHOL, PROPYL CARBINOL, BUTYL ALCOHOL
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 5%
Other REC Limits:300 MG/CUM
OSHA PEL:50 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: HARMFUL. MAY AFFECT THE
BRAIN & NERVOUS SYSTEM. CAUSES NOSE & THROAT IRRITATION. SKIN:
IRRITATION WHICH CAUSES DERMATITIS. EYES: BUTANOL MAY CAUSE DAMAGE.
INGESTION: MAY CAUSE GI IRRITATIO N. EFFECTS IN HUMAN HAVE INCLUDED
LIVER& CARDIAC ABNORMALITIES. (SEE SUP)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DIZZINESS, HEADACHE, NAUSEA,
STAGGERING GATE, CONFUSION, UNCONSCIOUSNESS, COMA, VOMITING,
DIARRHEA.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH IMMEDIATELY
W/LARGE AMOUNTS OF WATER FOR 15 MINS. SKIN: WASH AREA W/SOAP &
WATER. INGESTION: DON'T INDUCE VOMITING. KEEP WARM & QUIET.
ASPIRATION HAZARD. O BTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT & SCBA. WATER SPRAY
MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE PREFERRED.
(SEE SUPP)
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION, VENTILATE AREA
& REMOVE W/INERT ABSORBENT & NON SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE >120F. STORE LARGE
QUANTITIES IN BUILDINGS DESIGNED & PROTECTED FOR STORING FLAMMABLE
LIQUIDS.
Other Precautions:CONTAINERS SHOULD BE GROUNDED WHEN POURING. EMPTY
CONTAINERS MAY BE HAZARDOUS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED CHEMICAL CARTRIDGE RESPIRATOR
TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY & ORGANIC VAPORS
DURING SPRAY APPLICATION. CONFINED AREAS: USE NIOSH APPROVED
SUPPLIED AIR RESPIRATORS/ HOODS.
Ventilation:PROVIDE GENERAL DILUTION/LOCAL EXHAUST
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
FIRE PROCEDURES CONT'D: WATER MAY BE USED TO COOL CLOSED CONTAINERS TO
PREVENT PRESSURE BUILDUP & POSSIBLE AUTOIGNITION/EXPLOSION. HEALTH
HAZARD CONT'D: ASPIRATION OF THIS MATERIAL INTO LUNGS CAN CAUS E
CHEMICAL PNEUMONITIS WHICH CAN BE FATAL.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:243-284F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:61
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, HOT SURFACES.
Hazardous Decomposition Products:CO, CO2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T INCINERATE CLOSED CONTAINERS. DISPOSE OF
IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:317 BARE WIRE
CAGE:34920
CO
CAGE:34920
CAGE:27911
============= Composition/Information on Ingredients =============
Ingred Name:GRAPHITE, SYNTHETIC
CAS:7440-44-0
RTECS #:FF5250100
Fraction by Wt: 0.08%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9293
Ingred Name:CHROMIUM (SARA III)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 20.5%
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 15.0%
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
Fraction by Wt: 3.0-4.0%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9293
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 1.0-2.5%
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:SILICA, CRYSTALLINE - FUSED
CAS:60676-86-0
RTECS #:VV7328000
Fraction by Wt: 0.65%
Other REC Limits:30 MG/CUM TOTAL DUST
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:COPPER (SARA III)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 0.75%
Other REC Limits:0.2 MG/CUM FUMES
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2MG/M3 FUME; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: BALANCE
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:YES
Health Hazards Acute and Chronic:SHORT TERM EXPOSURE TO WELDING FUME
MAY RESULT IN DISCOMFORT, DIZZINESS, NAUSEA, DRYNESS OR IRRITATION
OF THE THROAT.
Explanation of Carcinogenicity:NICKEL & CHROMIUM SHOULD BE CONSIDERED
POSSIBLE CARCINOGENS.
Effects of Overexposure:LONG TERM EXPOSURE TO WELDING FUME, GASES OR
DUST MAY CONTRIBUTE TO PULMONARY IRRITATION OR PNEUMOCONIOSIS. LONG
TERM EXPOSURE TO IRON FUME MAY PRODUCE SIDEROSIS, WHICH IS
GENERALLY REGARDED AS BENIGN .
===================== Fire Fighting Measures =====================
Unusual Fire/Explosion Hazard:NONFLAMMABLE. WELDING ARC, OPEN FLAME &
SPARKS CAN IGNITE COMBUSTIBLES.
======================Handling and Storage ======================
Handling and Storage Precautions:TRAIN THE EMPLOYEE TO KEEP HIS HEAD
OUT OF THE FUMES.
Other Precautions:ONE RECOMMENDED WAY TO DETERMINE THE COMPOSITION &
QUANTITY OF FUMES & GASES TO WHICH WORKERS ARE EXPOSED IS TO TAKE
AN AIR SAMPLE FROM INSIDE THE WELDER'S HELMET IF WORN OR IN THE
WORKER'S BREATHINGZONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR WHEN WELDING, BRAZING, OR SOLDERING
IN CONFINED SPACE, IF >TLV
Ventilation:PROVIDE LOCAL EXHAUST VENTILATION TO KEEP THE FUMES & GASES
<TLV
Other Protective Equipment:ARM PROTECTORS, APRONS, HATS, SHOULDER
Supplemental Safety and Health
WELDING WIRE IS A NONHAZARDOUS SOLID AT AMBIENT TEMPERATURE. HAZARDS
MAY RESULT FROM FUME GENERATED DURING WELDING.
================== Physical/Chemical Properties ==================
Appearance and Odor:SOLID WIRE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO, CO2, OZONE, OXIDES OF METAL &
NITROGEN.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MOUNTING MEDIUM
Preparer's Name:DOD-HMIS (DGSC-SSH)
CAGE:65554
CAGE:65554
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 40%*
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III) *THE SOLVENT FOR
THE MOUNTING MEDIUM MAY BE EITHER TOLUENE OR XYLENE, NOT BOTH.*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 40%*
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:RESIN
Fraction by Wt: 60%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:PER DEFENSE MEDICAL PURCHASE
DESCRIPTION, PRODUCT CONTAINS TOLUENE OR XYLENE AS THE SOLVENT.
INHALING THE FUMES IS THE MOST LIKELY HAZARD. INHALING THESE FUMES
WILL CAUSE CNS DEPRESSION, DIZZINESS, HE ADACHE, ETC.
INTENTIONALLY CONCENTRATING THEM MAY BE HARMFUL. CHRONIC
OVEREXPOSURE CAUSES CNS DAMAGE.
Explanation of Carcinogenicity:RESIN PORTION OF THE MEDIUM IS UNKNOWN,
BUT IS NOT EXPECTED TO CONTAIN ANY CARCINOGENS.
Effects of Overexposure:OVEREXPOSURE MAY LEAD TO RESPIRATORY
IRRITATION, NAUSEA, FATIGUE, DIZZINESS, HEADACHES, UNCONSCIOUSNESS.
SKIN CONTACT MAY CAUSE DERMATITIS.EYE CONTACT CAUSES IRRITATION.
Medical Cond Aggravated by Exposure:PERSONS WITH A SKIN DISORDER SHOULD
USE CAUTION WHEN HANDLING OR USING THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WATER 15 MIN, HOLD LIDS OPEN. SKIN:WASH WITH SOAP
& WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE.
INHALED:REMOVE TO FRESH AIR. RESTORE BREATHING IF NECESSARY.
INGESTED:DO N OT INDUCE VOMITING. GIVE 2 LARGE GLASSESOF MILK OR
WATER AND GET IMMEDIATE MEDICAL CARE. DOCTOR TO ORDER VOMITING.
NOTHING BY MOUTH IF UNCONSCIOUS. IF IRRITATION PERSISTS OR IS
SEVERE,SEE A DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:EST. 45.0F,7.2C
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP SPILLED MATERILA WITH PAPER OR CLOTH.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, VENTILATED WORK AREA.
KEEP CONTAINERS CLOSED WHEN NOT IN USE. FLAMMABLE LIQUID, EMPTY
CONTAINERS CAN BE HAZARDOUS.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR WILL NOT NORMALLY BE NECESSARY. USE
NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR OR RESPIRATOR FOR
ORGANIC VAPORS IF EXPOSURE IS ABOVE THE TLV/PEL. SEE 29 CFR
1910.134 FOR REGULATIONS PERTA INING TO RESPIRATOR USE.
Ventilation:NOT NORMALLY REQUIRED. USE LAB HOOD OR OTHER LOCAL EXHAUST
TO MAINTAIN EXPOSURE BELOW PEL/TLV.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER, LAB COAT
OR APRON TO PROTECT EXPOSED SKIN.
Work Hygienic Practices:USE GOOD CHEMICAL HYGIENE PRACTICE. AVOID
UNNECESSARY CONTACT. WASH THOROUGHLY BEFORE EATING OR DRINKING.
Supplemental Safety and Health
ACE SCIENTIFIC IS OUT OF BUSINESS. THIS MSDS WRITTEN AROUND DPSC
PURCHASE DESCRIPTION.
================== Physical/Chemical Properties ==================
HCC:F2
Solubility in Water:NEGLIGIBLE
Appearance and Odor:YELLOW LIQUID
Percent Volatiles by Volume:40
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
OTHER HYDROCARBON COMPOUNDS DURING COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W ALL FEDERAL, STATE AND LOCAL
REGULATIONS. MANUFACTURER SUGGESTS THAT DISPOSAL MAY BE DONE BY
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DURALUM HRG
Preparer's Name:KIMBERLEY MINKEL
CAGE:27715
CAGE:27715
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM OXIDE (SARA 313)
CAS:1344-28-1
RTECS #:BD1200000
Fraction by Wt: 92-99%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 1.4%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:IRON OXIDE
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 0.1-1.5%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG(FE)/M3 FUME, B2
Ingred Name:SILICON DIOXIDE (SIO2)
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 0.2-1.7%
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:OTHER OXIDES
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: MAY IRRITATE. SKIN: NOT
ABSORBED THROUGH THE SKIN. MAY CAUSE ABRASIONS. INGESTION: NO KNOWN
ADVERSE EFFECTS, BUT INGESTION NOT RECOMMENDED. INHALATION: MAY
CAUSE COUGHING OR SHORTNESS OF BREATH. CHRONIC: MAY AFFECT
BREATHING CAPACITY.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: WASH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. GET MEDICAL ATTENTION, IF NEEDED. SKIN: WASH WITH WATER.
OBTAIN FIRST AID OR MEDICAL ASSISTANCE IF NEEDED. INGESTION: IF
SWALLOWED, SEEK MEDICAL ATTENTION. INHALATION: REMOVE TO FRESH
AIR, APPLY ARTIFICIAL RESPIRATION AS NEEDED. GET MEDICAL ATTENTION
IF NEEDED.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:NON-FLAMMABLE. USE MEDIA SUITABLE FOR SURROUNDING
FIRE .
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. NORMAL CLEANUP
PROCEDURES. AVOID GENERATING DUST. DISPOSE ACCORDING TO STANDARD
LANDFILL METHODS CONSISTENT WITH APPLICABLE FEDERAL, STATE AND
LOCAL LAWS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:GENERAL STORAGE, AMBIENT AIR
TEMPERATURE AND PRESSURE.
Other Precautions:AVOID GENERATING DUST. HANDLE WITH ADEQUATE
VENTILATION FOR DUST. SEE OSHA 29 CFR 1910.94 (VENTILATION).
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RECOMMENDED IF TLVS OR PELS ARE EXCEEDED. USE
NIOSH APPROVED RESPIRATOR.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURES BELOW PELS OR TLVS.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:3704F,2040C
Spec Gravity:3.95
Solubility in Water:INSOLUBLE
Appearance and Odor:GRANULAR BROWN TO BLACK, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:APPROVED LANDFILL IN ACCORDANCE WITH ALL LOCAL,
SATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SULFAMIC ACID
CAGE:83628
CAGE:83628
============= Composition/Information on Ingredients =============
Ingred Name:SULFAMIC ACID
CAS:5329-14-6
RTECS #:WO5950000
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS 3160 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF SWALLOWED, INHALED OR
ABSORBED THROUGH SKIN. MATERIAL IS EXTREMELY DESTRUCTIVE TO TISSUE
OF THE MUCOUS MEMBRANES AND UPPER RESPIRATORY TRACT, EYES AND SKIN.
INHALATION MAY BE FATAL AS A RES ULT OF SPASM, INFLAMMATION AND
EDEMA.
Explanation of Carcinogenicity:NOT CARCINOGENIC.
Effects of Overexposure:SYMPTOMS OF OVEREXPOSURE MAY INCLUDE BURNING
SENSATION, COUGHING, WHEEZING, LARYNGITIS, SHORTNESS OF BREATH,
HEADACHE, ANUSEA AND VOMITING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:IN CASE OF CONTACT, IMMEDIATELY FLUSH EYES OR SKIN WITH
COPIOUS AMOUNTS OF WATER FOR AT LEAST 15 MIN WHILE REMOVING
CONTAMINATED CLOTHING & SHOES. IF INHALED, REMOVE TO FRESH AIR. IF
NOT BREATHING GIV E ARTIFICIAL RESPIRATION. IF BREATHING IS
DIFFICULT, GIVE OXYGEN. IF SWALLOWED, WASH OUT MOUTH WITH WATER
PROVIDED PERSON IS CONSCIOUS. CALL A PHYSICIAN. DISCARD
CONTAMINATED SHOES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER OR APPROPIATE
FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING TO PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR SELF-CONTAINED BREATHING
APPARATUS, RUBBER BOOTS
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP
TIGHTLY CLOSED. ISOLATE FROM INCOMPATIBLE MATERIALS. AVOID CONTACT
AND INHALATION.
Other Precautions:MECHANICAL EXHAUST REQUIRED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED IF VENTILATION CONTROLS ADEQUATE.
USE NIOSH/MSHA APPROVED RESPIRATOR IF ENGINEERING CONTROLS ARE NOT
IN PLACE OR INADEQUATE. IF RESPIRATORY PROTECTION IS USED; A
PROGRAM IN ACCORDANCE WI TH 29 CFR 1910.134 MUST BE IMPLEMENTED.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION OR LOCAL EXHAUST TO
DUST LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER, CLOTHING
TO PREVENT REPEATED OR PROLONGED CONTACT.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
DO NOT GET IN EYES, ON SKIN OR CLOTHES.
================== Physical/Chemical Properties ==================
HCC:C1
Melt/Freeze Pt:M.P/F.P Text:419F,215C
Appearance and Odor:WHITE CRYSTAL.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG BASES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:SULFUR OXIDES, NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. ALDRICH/SIGMA: DISSOLVE OR MIX WITH A
COMBUSTIBLE SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED
WITH AFTERBURNER AND SCRUBBER. EPA WASTE NUMBER= D002 (CORROSIVE
WASTE).
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:7021, ALCAN ALUMINUM METAL 7XXX SERIES ALLO
CAGE:01371
CAGE:01371
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 97.7%
OSHA PEL:15 MG/M3 DUST;5 FUME
ACGIH TLV:10 MG/M3 DUST;5 FUME
Ingred Name:MAGNESIUM
CAS:7439-95-4
RTECS #:OM2100000
Fraction by Wt: 1.2-1.8%
Ingred Name:ZINC (EXPOSURE LISTED FOR ZINC OXIDE)
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: 5.0-6.0%
OSHA PEL:10 MG/M3 DUST; 5FUME
ACGIH TLV:10 MG/M3 DUST; 5FUME
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:CHROMIUM (SARA III)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 0.05%
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SUPP DATA:THEREFORE, CAUTION NEEDS TO BE EXERCISED IF
METAL COULD BE HOT. INGOTS IN THIS SERIES MAY HAVE HIGH (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:INTERNAL STRESSES & SHOULD, THEREFORE, BE
STRESS-RELIEVED TO PREV EXPLOS FROM OCCURRING DURING SAWING
OPERATIONS.
RTECS #:9999999ZZ
Ingred Name:MATL TO AVOID:DIVIDED ALUMINUM CAN FORM EXPLOSIVE MIXTURES
WITH BROMATES, IODATES, AND AMMONIUM NITRATE.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP:OF ALUMINUM ALLOYS CAN GENERATE OZONE,
NITRIC OXIDES, & ULTRAVIOLET RADIATION. OZONE OVEREXP MAY (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:RESULT IN MUCOUS MEMBRANE IRRITATION, AS WELL AS
OTHER PULMONARY DISCOMFORTS.
RTECS #:9999999ZZ
Ingred Name:VENT:PROVISIONS MAY BE REQUIRED. SEE NATIONAL FIRE
PROTECTION ASSOCIATION CODES NFPA 65 AND 651.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL:ALUMINUM DUST IS CONSIDERED
NUISANCE PARTICULATES, WHICH HAVE LITTLE ADVERSE EFTS ON LUNGS & DO
NOT PRODUCE SIGNIFICANT ORGANIC DISEASE/TOX EFT WHEN EXPOS ARE KEPT
UNDER REASONABLE CONTROL. ALUM INUM FUMES GENERATED IN
MELTING/WELDINGARE CONSIDERED TO BE LOW HLTH RISK. SKIN:NOT
APPLICABLE. EYE:(EFTS OF OVEREXP)
Explanation of Carcinogenicity:CHROMIUM:GROUP 1 (IARC, NTP).
Effects of Overexposure:HLTH HAZ:ALUMINUM DUST MAY CAUSE ABRASIONS.
INGEST:NONE SPECIFIED BY MFR. INHAL:DUE TO LOW CONC OF OTHER LISTED
INGRED, THEIR PRESENCE IS LESS LIKELY TO CAUSE HLTH CONCERN. HEAVY
CONC OF FRESHLY FORME D FUMES OF OXIDES OF MAGNESIUM & ZINC CAN
PRODUCE SYMP OF METAL FUME FEVER. MIG WELDING OR PLASMA ARC CUTTING
(ING 8)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:IN CASE OF DISCOMFORT, MOVE TO A VENTILATED AREA. IF
DISCOMFORT PERSISTS, SEEK MEDICAL ATTENTION. SKIN:FLUSH WITH
COPIOUS AMOUNTS OF WATER, CALL MD IMMEDIATELY . EYE:FLUSH WITH
WATER FOR A T LEAST 15 MINUTES AND IF IRRITATION PERSISTS, SEEK
MEDICAL ATTENTION. INGEST:CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:NOT FIRE HAZ EXCEPT IN FINELY DIVIDED FORM. IN CASE
OF AN ALUMINUM FIRE, USE A CLASS D DRY POWDER EXTING/DRY (SUPP
DATA)
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . DO NOT USE WATER OR HALOGENATED
EXTINGUISHING MEDIA.
Unusual Fire/Explosion Hazard:MOLTEN ALUMINUM MAY EXPLODE UPON CNTCT W/
WATER. FINELY DIVIDED ALUMINUM MAY EXPLODE WHEN MIXED W/HALOGEN
ACIDS, HALOGENATED SOLV/AMMONIUM NITRATE. (SUPP DATA)
================== Accidental Release Measures ==================
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:APPROPRIATE NIOSH/MSHA APPROVED RESPIRATORY
PROTECTION FOR CONCENTRATIONS ABOVE THE EXPOSURE LIMITS.
Ventilation:IF VENT IS TO BE USED TO CONVEY FINELY DIVIDED ALUMINUM
GENERATED BY GRINDING, SAWING/ETC., SPECIAL VENT (ING 10)
Other Protective Equipment:MOLTEN METAL HNDLG REQ USE OF BOTH SECONDARY
& PRIMARY PERS FIRE PROT EQUIP REFER TO ALUMINUM ASSOC.'S
GUIDELINES.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXTING MEDIA:SAND. DO NOT USE WATER/ HALOGENATED EXTING MEDIA. EXPLOS
HAZ:FINELY DIVIDED ALUMINUM REACTS W/ HALOGEN ACIDS, WATER, &
SODIUM HYDROXIDE TO PRDCE HYDROGEN GAS. CNDTNS TO AVOID:OF OXIDES
OFCOPPER, LEAD/IRON. HOT ALUMINUM DOES NOT EXHIBIT ANY WARNING
COLOR CHANGES, (ING 5)
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:>482F,>250C
Spec Gravity:2.5-2.9(H2O=1)
Appearance and Odor:GREY TO SILVER METALLIC SOLID; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALUMINUM CAN GENERATE EXPLOS MIXTURES OF HYDROGEN IN PRESENCE OF
HALOGEN ACIDS/SODIUM HYDROXIDE. FINELY (ING 7)
Stability Condition to Avoid:ALUMINUM SCRAP MUST BE THORO DRIED PRIOR
TO REMELTING. FINELY DIVIDED ALUMINUM CAN THERMITE IN THE PRESENCE
(SUPP DATA)
==================== Disposal Considerations ====================
Waste Disposal Methods:RECYCLE. FINELY DIVIDED ALUMINUM MAY BE REACTIVE
AND ITS HAZARD CHARACTERISTICS SHOULD BE DETERMINED PRIOR TO
DISPOSAL. DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL
REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SOLUTION S0110 AKD-1 (LOW RANGE)
CAGE:89524
CAGE:89524
============= Composition/Information on Ingredients =============
Ingred Name:WATER, H2O
CAS:7732-18-5
RTECS #:ZC0110000
Ingred Name:SULFURIC ACID (SARA III)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: TRACE
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYE: NON-IRRITATING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN/EYE: NON-IRRITATING.
======================= First Aid Measures =======================
First Aid:SKIN/EYE: FLUSH CONTACT AREA W/WATER. OBTAIN MEDICAL
ATTENTION.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO LABORATORY DRAIN OR SEWER W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATORY PROTECTION ISN'T NEEDED.
Ventilation:MECHANICAL VENTILATION IS RECOMMENDED
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:1.00
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS, LIQUID, NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:IF THIS PRODUCT BECOMES A WASTE, IT DOESN'T MEET
THE CRITERIA OF A HAZARDOUS WASTE AS DEFINED UNDER THE RCRA. FLUSH
TO LABORATORY DRAIN OR SANITARY SEWER WITH WATER.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:3817 MORPHINE SULFATE INJECTION USP
CAGE:4W445
CAGE:4W445
CAGE:0MRZ6
============= Composition/Information on Ingredients =============
Ingred Name:MORPHINE SULFATE *95-1*
CAS:6211-15-0
RTECS #:QC8760000
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 461-905 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: DEATH FROM PARALYSIS.
INHALATION: ABSORBED THROUGH NASAL & RESPIRATORY MUCOSA. SKIN:
UTICARIA & BRONCHIAL SPASM. PRODUCES DEPENDENCE. REPORTED TO BE
MUTAGENIC & TERATOGENIC. (SEE SUPPLEMENT AL DATA)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:ALTERED RESPIRATION, PINPOINT PUPILS, NAUSEA,
VOMITING, CONSTIPATION, URINE RETENTION, WEAK PULSE, MUSCLE
TWITCHING/SPASM, CYANOSIS, COMA, ITCHING, MIOSIS, REDUCTION IN
VISUAL FIELD, BLURRED VISION.
======================= First Aid Measures =======================
First Aid:INGESTION: MAINTAIN RESPIRATION. ADMINISTRATION OF A SPECIFIC
NARCOTIC ANTAGONIST & OBSERVATION FOR 24-48 HOURS ARE ADVISED.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/SUITABLE MATERIAL & FLUSH W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID EXCESSIVE STORAGE TEMPERATURE &
PROTECT FROM LIGHT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED.
Ventilation:NO SPECIAL PROVISIONS REQUIRED.
Supplemental Safety and Health
INCOMPATIBILITY CONT'D: MAGNESIA/MERCURY BICHLORIDE. HEALTH RELATED
DATA FOR THIS PRODUCT BASED ON MORPHINE SULFATE CONTENT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text: AS WATER
Melt/Freeze Pt:M.P/F.P Text: AS WATER
Spec Gravity: AS WATER
pH:2.5-6
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIQUID
Percent Volatiles by Volume:NEGLI
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALIES/TANNIC ACID/IODIC ACID/POTASSIUM
PERMANGANATE/BORAX/CHLORATES/FERRIC CHLORIDE/IODIDES/LEAD ACETATE
(SEE SUPP)
Stability Condition to Avoid:LIGHT & HIGH TEMPS.
Hazardous Decomposition Products:OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF SOLUTION IN SEWER. BURY IN LANDFILL.
DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SC-118 CADMIUM REFERENCE STANDARD SOLUTION
CAGE:63415
CAGE:63415
============= Composition/Information on Ingredients =============
Ingred Name:CADMIUM, CADMIUM PIGMENT (SUSPECTED HUMAN CARCINOGEN BY
ACGIH, IARC & NTP)INTENDED CHANGE (IC)
CAS:7440-43-9
RTECS #:EU9800000
Fraction by Wt: 0.1%
Other REC Limits:A2 CARCINOGEN
OSHA PEL:SEE 1910.1027
ACGIH TLV:0.01 MG/M3 DUST;9394
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:NITRIC ACID, HYDROGEN NITRATE
CAS:7697-37-2
RTECS #:QU5775000
Fraction by Wt: 1.4%
OSHA PEL:5 MG/CUM
ACGIH TLV:5.2 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 98.5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION/SKIN/EYES: IRRITATION.
INGESTION: ASPIRATION MAY OCCUR DUE TO VOMITING.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:INHALATION/INGESTION: NEPHROTOXIN EFFECTS.
POISONING MAY AFFECT THE LIVER, BONE, BLOOD, LUNGS, & THE NERVOUS
SYSTEM.
Medical Cond Aggravated by Exposure:KIDNEY/RESPIRATORY/SKIN/EYE
DISORDERS, IMPAIRED PULMONARY FUNCTION, DEFICIENCIES IN IRON,
CALCIUM, ZINC, PROTEIN, & VITAMINS C & D MAY ENHANCE THE TOXIC
EFFECTS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN. MAINTAIN
AIRWAY/BLOOD PRESSURE. KEEP WARM/QUIET. SKIN: WASH W/SOAP/MILD
DETERGENT & WATER. COVER W/STERILE/DRY DRESSING. BANDAGE SECURE.
EYE: WASH W/W ATER/NORMAL SALINE. COVER W/STERILE BANDAGE.
INGESTION: DON'T USE GASTRIC LAVAGE/EMESIS. DRINK WATER/MILK.
DILUTE 100 FOLD. KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION. TREAT
SHOCK. OBTAIN MED ATTN.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL/CO2/HALON/WATER SPRAY/STANDARD FOAM.
LARGE FIRE: WATER SPRAY/FOG/STANDARD FOAM. DON'T USE WATER
DIRECTLY.
Fire Fighting Procedures:MOVE CONTAINERS FROM AREA. COOL CONTAINERS
EXPOSED TO FLAMES W/WATER FROM SIDE UNTIL WELL AFTER FIRE IS OUT.
STAY AWAY FROM STORAGE TANK ENDS. KEEP UPWIND.
================== Accidental Release Measures ==================
Spill Release Procedures:SOIL: DIG HOLDING AREA/DIKE W/SOIL
BARRIER/SANDBAG/FOAMED POLYURETHANE/FOAMED CONCRETE. ABSORB LIQUID
MASS W/FLY ASH/CEMENT POWDER. AIR: APPLY WATER SPRAY. WATER: ADD
SUITABLE AGENT TO NEUTRALIZE. KEE P UNNECESSARY PEOPLE AWAY. STOP
LEAK SAFELY.
Neutralizing Agent:SLAKED LIME, SODIUM BICARBONATE OR CRUSHED LIMESTONE
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT W/SKIN & EYES.
Other Precautions:AVOID BREATHING CORROSIVE VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CHEMICAL CARTRIDGE RESPIRATOR W/ACID GAS
CARTRIDGE, TYPE C SUPPLIED-AIR RESPIRATOR, SCBA W/FULL FACEPIECE
OPERATED IN PRESSURE-DEMAND/POSITIVE PRESSURE MODE W/HELMET OR HOOD
OPERATED IN CONTINUOUS-FLO W MODE W/AUXILIARY SCBA.
Ventilation:LOCAL EXHAUST: TO KEEP BELOW EXPOSURE LIMITS.
Other Protective Equipment:SPLASH-PROOF OR DUST-RESISTANT SAFETY
DRENCH SHOWER
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING & SHOES
IMMEDIATELY & LAUNDER BEFORE REUSE.
Supplemental Safety and Health
NOTE TO PHYSICIAN: NO SPECIFIC ANTIDOTE. TREAT SYMPTOMATICALLY &
SUPPORTIVELY.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F (100C)
Melt/Freeze Pt:M.P/F.P Text:32F (0C)
Vapor Pres:14
Vapor Density:0.7
Spec Gravity:1
Evaporation Rate & Reference:(ETHER = 1): >1
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, BASES, METALS, COAL, FUEL OIL, RUBBER, AIR, ORGANIC MATTER
Stability Condition to Avoid:FLAMES, HEAT
Hazardous Decomposition Products:TOXIC CADMIUM OXIDE & HIGHLY TOXIC
FUMES OF OXIDES OF NITROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. REPORTABLE QUANTITIES: CADMIUM = 10 LBS;
NITRIC ACID = 1000 LBS. AVOID CONTAMINATION OF ANY SOURCE OF
DRINKING WATER.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:224 FORMULA
CAGE:94058
CAGE:94058
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM HYDROXIDE
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 5-10%
Other REC Limits:2 MG/CUM (CEILING)
ACGIH TLV:2 MG/CUM (CEILING)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION TO RESPIRATORY
TRACT & CHEMICAL PNEUMONITIS. EYES: MAY CAUSE SEVERE TO PERMANENT
INJURY. INGESTION: MAY CAUSE SEVERE BURNS OF MUCOUS MEMBANES OF THE
MOUTH, THROAT, ESOPHAGUS & S TOMACH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, PAIN, VOMITING, COLLAPSE & REDNESS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LARGE AMOUNTS OF WATER FOR 15 MINS. INHALATION:
REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT, GIVE OXYGEN. SKIN:
WASH W/MILD SOAP & WATER. REMOVE/LAUNDER CONTAMINATED CLOTHING
BEFORE R EUSE. INGESTION: DON'T INDUCE VOMITING.DILUTE BY GIVING
WATER. GIVE MILK OF MAGNESIA IF AVAILABLE. KEEP WARM & QUIET. NEVER
GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. (SEE SUPP)
===================== Fire Fighting Measures =====================
Flash Point:NONE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: NEUTRALIZE W/MILD ACID SUCH AS
CITRIC/W/SODIUM BICARBONATE. RINSE TO SANITARY SEWER W/PLENTY OF
WATER. LARGE: ABSORB ON SOLID ABSORBENT & SHOVEL INTO CONTAINERS
FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BETWEEN 40F & 120F.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:MECHANICAL (GENERAL): SUFFICIENT
Other Protective Equipment:NONE
Work Hygienic Practices:AVOID BREATHING SPRAY MISTS. REMOVE/LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
FIRST AID CONT'D: OBTAIN MEDICAL ATTENTION IN ALL CASES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Melt/Freeze Pt:M.P/F.P Text:30F
Spec Gravity:1.344
Evaporation Rate & Reference:(WATER=1): 1
Solubility in Water:COMPLETE
Appearance and Odor:YELLOW LIQUID W/MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG MINERAL ACIDS.
Stability Condition to Avoid:FREEZING
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HEAVY DUTY MOTOR OIL, SAE 30 OR SAE 40
Preparer's Name:REGULATORY, ENVIRONMENTAL
CAGE:DO110
CAGE:70842
CAGE:0B2U4
CAGE:DO110
CAGE:050Q3
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENT REFINED HYDROTREATED RESIDUAL OIL
CAS:64742-57-0
Other REC Limits:NONE RECOMMENDED
Ingred Name:ORGANOMETALLIC ADDITIVES
Fraction by Wt: 10-30%
Other REC Limits:NONE RECOMMENDED
Ingred Name:METHACRYLATE POLYMER &/OR ETHYLENE-PROPYLENE COPOLYMER
W/NITROGEN FUNCTIONAL GROUP
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:THE FIRST 14 INGREDIENTS ARE LISTED TOGETHER AS "SEVERELY
REFINED PETROLEUM BASESTOCKS CONTAINING ONE OR MORE OF:"
RTECS #:9999999ZZ
Fraction by Wt: 60-100%
Other REC Limits:NONE RECOMMENDED
Ingred Name:MINERAL OIL
CAS:64742-41-2
Other REC Limits:NONE RECOMMENDED
Ingred Name:DISTILLATES, SOLVENT-DEWAXED LIGHT PARAFFINIC
CAS:64742-56-9
RTECS #:PY8039500
Other REC Limits:NONE RECOMMENDED
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATE, SOLVENT DEWAXED
(SEVERE), HEAVY PARAFFINIC
CAS:64742-65-0
RTECS #:PY8038501
Other REC Limits:NONE RECOMMENDED
Ingred Name:HIGHLY REFINED BASE OIL
CAS:72623-85-9
Other REC Limits:NONE RECOMMENDED
Ingred Name:MINERAL OIL, SOLVENT REFINED HEAVY PARAFFINIC, SEVERELY
HYDROTREATED (NON-CARCINOGENIC - IARC)
CAS:64741-88-4
RTECS #:PY8040501
Other REC Limits:NONE RECOMMENDED
Ingred Name:HYDROTREATED MIDDLE PETROLEUM DISTILLATE
CAS:64742-46-7
RTECS #:JN9379645
Other REC Limits:NONE RECOMMENDED
Ingred Name:MINERAL OIL
CAS:72623-83-7
Other REC Limits:NONE RECOMMENDED
Ingred Name:SEVERELY HYDROTREATED HYDROCARBON OIL
CAS:72623-87-1
Other REC Limits:NONE RECOMMENDED
Ingred Name:SEVERELY REFINED PETROLEUM BASESTOCK
CAS:72623-86-0
Other REC Limits:NONE RECOMMENDED
Ingred Name:SOLVENT REFINED RESIDUM
CAS:64742-01-4
Other REC Limits:NONE RECOMMENDED
Ingred Name:MINERAL OIL,HYDROTREATED (SEVERE), PETROLEUM DISTILLATE,
HEAVY PARAFFINIC
CAS:64742-54-7
RTECS #:PY8035501
Other REC Limits:NONE RECOMMENDED
Ingred Name:SOLVENT DEWAXED RESIDUAL OIL (PETROLEUM)
CAS:64742-62-7
Other REC Limits:NONE RECOMMENDED
Ingred Name:SEVERELY REFINED PETROLEUM BASE STOCK
CAS:72623-84-8
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:PRODUCT'S LD50 (ORAL RAT) WAS NOT STATED
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-EYE/SKIN:NOT EXPECTED TO CAUSE
PROLONGED OR SIGNIFICANT IRRITATION. RESPIRATORY SYSTEM:UNLIKELY TO
BE HARMFUL W/NORMAL USE. INGESTION:LLOW ORDER TOXICITY, MAY CAUSE
G/I DISTURBANCES. CHRONIC-PRO LONGED &/OR REPEATED SKIN CONTACT MAY
CAUSE DEFATTING, DERMATITIS.
Explanation of Carcinogenicity:USED MOTOR OIL HAVE CAUSED SKIN CANCER
IN LAB ANIMALS IF REPEATEDLY APPLIED W/O WASHING BETWEEN
APPLICATIONS.
Effects of Overexposure:TRANSIENT EYE IRRITATION, REDNESS, TEARING. G/I
DISTURBANCES, DIARRHEA, HEADACHE, DROWSINESS, NAUSEA, VOMITING.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS.
======================= First Aid Measures =======================
First Aid:IF IRRITATION PERSISTS OR IS SEVERE, GET MEDICAL ATTENTION.
EYE:FLUSH W/WATER FOR 15 MIN. SKIN:WASH W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE. INHALED:REMOVE FROM
EXPOSURE. A ID OR RESTORE BREATHING AS NEEDED. INGESTED:DO NOT
INDUCE VOMITING W/O EXPRESS DIRECTION OF MEDICAL PERSONNEL. GIVE
PLENTY OF MILK OR WATER TO DRINK & GET IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:440F,227C
Autoignition Temp:Autoignition Temp Text:N/A.
Lower Limits:ND
Upper Limits:ND
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER FOG. DO NOT USE
WATER JETS.
Fire Fighting Procedures:MATERIAL MUST BE PREHEATED TO BURN. DO NOT
ENTER CONFINED SPACE W/O NIOSH APPROVED POSITIVE PRESSURE SCBA &
FULL PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:COOL FIRE EXPOSED CONTAINERS W/WATER.
================== Accidental Release Measures ==================
Spill Release Procedures:USE BEST ENGINEERING PRACTICE DURING CLEAN-UP.
LARGE SPILL:STOP LEAK. DIKE SPILL. RECOVER LIQUID. PREVENT ENTRY
INTO SEWERS, WATERWAYS. SMALL SPILL:NEUTRALIZE. STORE CONTAMINATED
ABSORBENT IN CLOSED C ONTAINER. REPORT SPILL AS REQUIRED.
Neutralizing Agent:MFR GAVE NO INFORMATION OF MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE. DO NOT STORE NEAR IGNITION SOURCES & STRONG OXIDENTS. MAINTAIN
ADEQUATE VENTILATION. AVOID BREATHING MIST.
Other Precautions:AVOID PROLONGED &/OR REPEATED SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE UNDER NORMAL USE. IF EXPOSURE IS EXPECTED
TO EXCEED OCCUPATIONAL EXPOSURE LIMITS, USE NIOSH-APPROVED
RESPIRATOR TO PREVENT OVEREXPOSURE. COMPLY W/29CFR1910.134.
Ventilation:NO SPECIAL VENTILATION IS NORMALLY NECESSARY. USE
SPECIAL/LOCAL EXHAUST IF HIGH AIRBORNE CONCENTRATIONS OCCUR.
Other Protective Equipment:NO SPECIAL REQUIREMENT. NORMAL WORK
CLOTHING, COVERALL, APRON MAY BE USED TO MINIMIZE SKIN CONTACT.
Work Hygienic Practices:AVOID PROLONGED &/OR REPEATED SKIN CONTACT. DO
NOT WEAR CONTAMINATED CLOTHING. REMOVE & LAUNDER BEFORE REUSE.
Supplemental Safety and Health
WASH THOROUGHLY W/SOAP & WATER AFTER HANDLING.
================== Physical/Chemical Properties ==================
HCC:V6
NRC/State Lic Num:NONE
Boiling Pt:B.P. Text:>500F,>260C
Melt/Freeze Pt:M.P/F.P Text:-22F,-30C
Vapor Pres:<0.01 MM
Vapor Density:>1
Spec Gravity:0.89
pH:NA
Evaporation Rate & Reference:<0.1 (BU AC = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, AMBER LIQUID W/MILD PETROLEUM ODOR.
Percent Volatiles by Volume:NEG
Corrosion Rate:UNKNOWNN
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS.
Stability Condition to Avoid:STABLE UNDER AMBIENT TEMPERATURES. AVOID
HEAT & OPEN FLAME.
Hazardous Decomposition Products:SMOKE, FUMES, OXIDES OF CARBON.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF PROPERLY. IF DISCARDED AS SUPPLIED
THE MATERIAL IS CORROSIVE (RCRA). USE MAY CAUSE IT TO EXHIBIT MORE
HAZARDOUS CHARACTERISTICS. MATERIAL MUST BE PACKAGED, LABELED,
TRANSPORTED & DISPOSED I /A/W FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PROGOLD G 100 SPRAY,57 GRAMS,G 100 S-2
Preparer's Name:MARK K. LOHKEMPER
CAGE:55403
Contract Num:SPO-450-01-M-D856
CAGE:55403
============= Composition/Information on Ingredients =============
Ingred Name:ETHANE, 1,1-DIFLUORO/DIFLUOROETHANE
CAS:75-37-6
RTECS #:KI1410000
Fraction by Wt: 90%
Other REC Limits:NONE RECOMMENDED
Ingred Name:PROGOLD G100L LIQUID/PROGOLD
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS UNKNOWN.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY &
GI TRACTS. ACUTE- MAY CAUSE EYE IRRITATION. SKIN CONTACT CAN CAUSE
DEFATTING & DRYNESS. INGESTION MAY CAUSE VOMITING. ASPIRATION OF
MATERIAL INTO LUNGS MAY CAUSE LUNG DAMAGE. INHALATION OF VAPORS
MAY CAUSE RESPIRATORY IRRITATION, DROWSINESS, UNCONSCIOUSNESS.
CHRONIC- DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIFFICULTY IN BREATHING,
NAUSEA, VOMITING, DIZZINESS, FATIGUE, CONFUSION, DERMATITIS,
BLURRED VISION, TEARING, PAIN, ABDOMINAL CRAMPING, DIARRHEA,
UNCONSCIOUSNESS
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING
DISEASES OF THE EYE, SKIN, RESPIRATORY TRACT MAY HAVE INCREASED
SUSCEPTIBILITY TO THE TOXICITY OF EXCESSIVE EXPOSURES.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. EYES:FLUSH WITH
WATER FOR 15 MINUTES. HOLD EYELIDS OPEN. SKIN:WASH WITH SOAP &
WATER. INHALED:REMOVE TO FRESH AIR. PROVIDE CPR/OXYGEN IF
NECESSARY. ORAL:CALL PHYSICIAN AT ONCE. INDUCE VOMITING ONLY AS
DIRECTED BY MEDICAL PERSONNEL. IF CONSCIOUS, RINSE MOUTH WITH
WATER. KEEP PERSON WARM & QUIET. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:FLAMMABL AEROSOL
Lower Limits:3.9
Upper Limits:16.9
Extinguishing Media:USE CARBON DIOXIDE (CO2), ALCOHOL FOAM OR DRY
CHEMICAL. USE WATER SPRAY TO COOL FIRE EXPOSED CONTAINERS.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS. DO NOT USE
WATER.
Unusual Fire/Explosion Hazard:SPRAY CANS UNDER PRESSURE. EXTREMELY
FLAMMABLE. EXPLOSION HAZARD EXISTS WHEN SPRAY CANS HEATED. DO NOT
ENTER SPRAY CAN STORAGE AREA IF FIRE PRESENT.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE IGNITION SOURCES.
LEAKING CONTAINERS SHOULD BE PLACED OUTDOORS, IN AN OPEN CONTAINER,
AWAY FROM SOURCES OF IGNITION. ALLOW PRESSURE TO DISSIPATE. ABSORB
SPILL WITH NON-FLAMMABLE ABSORBENT AND PLACE IN CONTAINER FOR
DISPOSAL.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE SPRAY CANS IN COOL, WELL
VENTILATED AREAS AWAY FROM SOURCES OF IGNITION & STRONG OXIDIZING
AGENTS. DO NOT STORE IN DIRECT SUNLIGHT.
Other Precautions:"EMPTY" CONTAINERS RETAIN RESIDUE AND MAY BE
DANGEROUS. FOLLOW ALL LABEL INSTRUCTIONS. AVOID REPEATED/PROLONGED
SKIN CONTACT. KEEP OUT OF REACH OF CHILDREN. DO NOT BREATHE VAPORS.
DO NOT SPRAY TOWARD FACE/HOT SURFACES. WASH AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV IS EXCEEDED, WEAR NIOSH-APPROVED ORGANIC
VAPOR RESPIRATOR OR AIR-PURIFYING RESPIRATOR. IN EMERGENCY, WEAR A
NIOSH-APPROVED POSITIVE-PRESSURE SELF-CONTAINED BREATHING
APPARATUS.
Ventilation:MECHANICAL (GENERAL AND/OR LOCAL EXHAUST, EXPLOSION-PROOF)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWERS SHOULD BE
AVAILABLE IN THE IMMEDIATE VICINITY OF ANY POTENTIAL EXPOSURE.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V3
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:572F LIQUID
Vapor Pres:4498
Vapor Density:2.4
Spec Gravity:0.85
Viscosity:NOT KNOWN
Appearance and Odor:RED LIQUID - HYDROCARBON ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES, DIRECT SUNLIGHT,
HOT METAL SURFACES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
HYDROCARBONS MAY BE FORMED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. DO NOT PUNCTURE, INCINERATE SPRAY CANS
EVEN AFTER USE. DO NOT FLUSH INTO DRAINS. DO NOT CONTAMINATE
ENVIRONMENT.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:8018W, ATOM ARC
CAGE:84021
CAGE:84021
============= Composition/Information on Ingredients =============
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:NICKEL
CAS:7440-02-0
RTECS #:QR5950000
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:POTASSIUM SILICATE
CAS:1312-76-1
Ingred Name:CALCIUM FLUORIDE (MFR CAS NO:7784-75-5)
CAS:7789-75-5
RTECS #:EW1760000
OSHA PEL:2.5 MG/M3 AS F
ACGIH TLV:2.5 MG/M3 AS F
Ingred Name:POTASSIUM ALUMINUM SILICATE (FELDSPAR); (POTASSIUM
FELDSPAR)
CAS:68476-25-5
Ingred Name:ZIRCONIUM DIOXIDE; (ZIRCONIUM SILICATE)
CAS:7440-67-2
OSHA PEL:5 MG/M3/10 STEL
ACGIH TLV:5 MG/M3/10 STEL
Ingred Name:IRON (III) OXIDE; (IRON)
CAS:1309-37-1
RTECS #:NO7400000
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:CHROMIUM (SARA III)
CAS:7440-47-3
RTECS #:GB4200000
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICIC ACID, (H*2SIO*3), DISODIUM SALT; (SODIUM SILICATE)
CAS:6834-92-0
RTECS #:XX9275000
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:FUMES & GASES CAN BE DANGEROUS TO YOUR
HEALTH. ACUTE:OVEREXPOSURE TO WELDING FUMES MAY RESULT IN
DISCOMFORT SUCH AS:DIZZINESS, NAUSEA, DRYING/IRRITATION OF NOSE,
THROAT/EYES. CHRONIC: OVEREXPOSURE MAY LEAD TO SIDEROSIS (IRON
DEPOSITS IN LUNGS) AND IS BELIEVED BY SOME INVESTIGATORS TO AFFECT
PULMONARY(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NICKEL ANTICIPATED TO BE CARCINOGEN
(NTP), GROUP 2B (IARC).
Effects of Overexposure:HLTH HAZ:FUNCTION. ARC RAYS CAN INJURE EYES AND
BURN SKIN. ELECTRIC SHOCK CAN KILL.
Medical Cond Aggravated by Exposure:AGGRAVATION OF PREEXISTING
RESPIRATORY OR ALLERGIC CONDITIONS MAY OCCUR IN SOME WORKERS.
======================= First Aid Measures =======================
First Aid:CALL FOR MEDICAL AID. EMPLOY FIRST AID TECHNIQUES RECOMMENDED
BY AMERICAN RED CROSS. INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO
FRESH AIR. SUPPORT BREATHING (GIVE OXYGEN OR ARTIFICIAL RESPIRAT
ION) . EYES:IMMEDIATELY FLUSH WITH POTABLE WATER FOR A MINIMUM OF
15 MINUTES, SEEK ASSISTANCE FROM MD . SKIN:FLUSH WITH COPIOUS
AMOUNTS OF WATER. CALL MD .
===================== Fire Fighting Measures =====================
Flash Point:NON FLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . THESE PRODUCTS AS SHIPPED ARE NONHAZARDOUS,
NONFLAMMABLE, NONEXPLOSIVE AND NONREACTIVE.
Unusual Fire/Explosion Hazard:WELDING ARC AND SPARKS CAN IGNITE
COMBUSTIBLES.
================== Accidental Release Measures ==================
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:READ AND UNDERSTAND MANUFACTURER'S
INSTRUCTIONS AND PRECAUTIONARY LABEL ON THIS PRODUCT.
Other Precautions:SEE AMERICAN NATIONAL STANDARD Z-49.1, SAFETY IN
WELDING AND CUTTING, PUB BY AMERICAN WELDING SOCIETY, P.O. BOX
351040, MIAMI, FL 33135 AND OSHA PUB 2206 (29 CFR 1910), US
GOVERNMENT PRINTING OFFICE, WASHINGTON DC 20402 FOR MORE DETAILS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRABLE FUME
RESPIRATOR OR AIR SUPPLIED RESPIRATOR WHEN WELDING IN CONFINED
SPACE/WHERE LOCAL EXHAUST/VENTILATION DOES NOT KEEP EXPOSURE BELOW
TLV.
Ventilation:USE ENOUGH VENTILATION LOC EXHAUST AT ARC/BOTH, TO KEEP
FUMES/GASES BELOW TLV'S IN WORKERS BREATHING ZONE/GENERAL AREA.
Other Protective Equipment:ARM PROT, APRON, HATS, SHOULDER PROTECTION
AS WELL AS DARK SUBSTANTIAL CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPEC #:MIL-E-0022200/10A, MIL 10018-MI, MIL 12018-MZ. HAZ DECOMP
PROD:GASEOUS REACTION PRODUCTS MAY INCLUDE CO, CO2. OZONE &
NITROGEN OXIDES MAY BE FORMED BY RADIATION FROM ARC.
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:FLUORIDES & COMPLEX OXIDES OF IRON,
MANGANESE, SILICON & WHEN PRESENT, NICKEL, CHROMIUM, MOLYBDENUM, &
COPPER. (SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSABLE CONTAINER OR
LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER, IN FULL COMPLIANCE
WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:STEPANFOAM F-302 T, 188548
CAGE:87558
CAGE:87558
CAGE:87570
============= Composition/Information on Ingredients =============
Ingred Name:ISOCYANIC ACID, METHYL-M-PHENYLENE ESTER; (BENZENE,
1,3-DIISOCYANATOMETHYL (TDI)) (SARA 313) (CERCLA)
CAS:26471-62-5
RTECS #:NQ9490000
Fraction by Wt: 20%
OSHA PEL:N/K
ACGIH TLV:0.005 PPM; 0.02 STEL
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: CONTACT IS PAINFUL AND
IRRITATING. SKIN: PROLONGED OR REPEATED CONTACT CAUSES IRRITATION.
INHALATION: MAY CAUSE RESPIRATORY SENSITIZATION AND IRRITATE SKIN,
EYES AND RESPIRATORY TRACT WIT H POSSIBLE PERMANENT DECREASE IN
LUNG FUNCTION. INGESTION: CONSULT A PHYSICIAN IMMEDIATELY.
CHRONIC:(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HEALTH HAZARDS: CHRONIC EFFECTS INCLUDE ASTHMA,
OTHER RESPIRATORY DISORDERS (BRONCHITIS, EMPHYSEMA, BRONCHIAL
HYPERREACTIVITY), SKIN ALLERGIES, ECZEMA. UNNECESSARY EXPOSURE TO
THIS PRODUCT OR ANY CHEM ICAL SHOULD BE AVOIDED. IN A NTP STUDY,TDI
WAS CARCINOGENIC WHEN GIVEN ORALLY TO RATS & MICE AT MAX TOLERATED
(SUPDAT)
Medical Cond Aggravated by Exposure:ASTHMA, OTHER RESPIRATORY DISORDERS
(BRONCHITIS, EMPHYSEMA, BRONCHIAL HYPERREACTIVITY), SKIN ALLERGIES,
ECZEMA.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMEDIATELY WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES. SKIN: WASH OFF WITH WATER. REMOVE CONTAMINATED CLOTHING
AND CLEAN BEFORE REUSE. INHALATION: REMOVE TO FRESH AIR. SUPPORT
BREATHING (GIVE O*2/ARTIFICIAL RESPIRATION) . INGESTION: CONSULT A
PHYSICIAN IMMEDIATELY. IF ANY SYMPTOMS PERSIST, CONSULT A PHYSICIAN
IMMEDIATELY. FOR ADDITIONAL MEDICAL INFO, CALL 1-800-228-5635.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>230F,>110C
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, FOAM OR WATER FOG.
CLASS BC, ABC FIRE EXTINGUISHER.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN ALL SPILLS AND LEAKS TO PREVENT
DICHARGE INTO THE ENVIRONMENT. VENTILATE AREA. SMALL SPILLS: SOAK
UP WITH ABSORBANT, SHOVEL INTO WASTE CONTAINER, FLUSH AREA WITH
WATER. LARGE SPILLS: RECOVER L IQUID FOR REPROCESSING OR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A DRY, WELL VENTILATED AREA
AT ABOUT 65-85F(18-30C). RELEASE PRESSURE CAREFULLY BEFORE OPENING
CONTAINERS.
Other Precautions:SPILLED MATERIAL IS SLIPPERY. WASH THOROUGHLY AFTER
HANDLING. IF INGESTED, CALL A PHYSICIAN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VAPORS ARE PRESENT, USE NIOSH APPROVED
RESPIRATOR FOR ORGANIC VAPORS, AIR-LINE RESPIRATOR, OR A
SELF-CONTAINED BREATHING APPARATUS.
Ventilation:USE VENTILATION ADEQUATE TO KEEP HAZARDOUS INGREDIENTS
BELOW THEIR TLV.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
WEAR PROTECTIVE CLOTHING TO PREVENT REPEATED OR PROLONGED CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
EFTS OF OVEREXP: DOSES. TDI WAS NOT CARCINOGENIC TO RATS IN A TWO-YEAR
INHALATION STUDY. WASTE DISP: REGULATIONS. EMPTY CONTAINER MAY
RETAIN VAPOR OR PRODUCT RESIDUE. OBSERVE ALL LABELED SAFEGUARDS UN
TIL CONTAINER IS CLEANED, RECONDITIONED, OR DESTROYED.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Vapor Density:LTR/AIR
Spec Gravity:1.10
Evaporation Rate & Reference:SLOWER THAN ETHYL ETHER
Solubility in Water:NOT KNOWN
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:1 (WT)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, ALCOHOLS, AMINES, ALKALIES, METAL COMPOUNDS (CATALYSTS).
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CYANIDES AND AMMONIA MAY BE FORMED.
==================== Disposal Considerations ====================
Waste Disposal Methods:RECOVER MATERIAL OR DISPOSE (INCINERATION IS
PREFERRED) IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL
REGULATIONS. MATERIAL COLLECTED WITH ABSORBANT MAY BE DISPOSED IN A
PERMITTED LANDFILL IN ACCORD ANCE WITH FEDERAL, STATE AND LOCAL
(SUPDAT)
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PRO-SEAL 870 B-2 #0870B121
Kit Part:Y
CAGE:83574
CAGE:83574
============= Composition/Information on Ingredients =============
Ingred Name:MAGNESIUM CHROMATE (SARA 313)
CAS:13423-61-5
Fraction by Wt: 25.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG/M3 (AS CR)
ACGIH TLV:0.05 MG/M3
Ingred Name:1,3 DIPHENYL GUANIDINE
CAS:102-06-7
Fraction by Wt: <5.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:MANGANESE DIOXIDE (SARA 313)
CAS:1313-13-9
RTECS #:OP0350000
Fraction by Wt: 40.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (CEILING)
ACGIH TLV:5 MG/M3
Ingred Name:HYDROGENATED TERPHENYLS (VP = 1 MMHG)
CAS:61788-32-7
RTECS #:WZ6535000
Fraction by Wt: 35.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.5 PPM
ACGIH TLV:0.5 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITANT. SKIN: IRRIT,
HARMFUL ABSORPTION, SENSITIZER. INHALATION: MAY CAUSE DIZZINESS,
DROWSINESS, FATIGUE, MANGANESE PNEUMONITIS, MANGANESE POISONING,
IRRITATION &HARMFUL ABSORPTION. IN GEST: HARMFUL ABSORPTION,
(APATHY, INSOMNIA, WEAKNESS IN LEGS, MUSCULAR TWITCHING, EMOTIONAL
DISTRESS. *
Effects of Overexposure:NK *MAY CAUSE PENETRATING ULCERS OF SKIN AND
MUCOUS MEMBRANES OF NOSE & PERFORATION OF CARTILAGINOUS NASAL
SEPTUM.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LUKE WARM WATER 15 MINUTES. IF SYMPTOMS
PERSIST, CONSULT DR. SKIN: WASH W/SOAP & WATER. IF SYMPTOMS
PERSIST, CONSULT DR. INHALATION: GET FRESH AIR. GET MEDICAL AID.
INGESTION: CONSULT DR .
===================== Fire Fighting Measures =====================
Flash Point:>200F,>93C
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER.
Fire Fighting Procedures:USE AIR-SUPPLIED RESPIRATOR. USE WATER TO COOL
HEAT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:EXCESSIVE HEAT MAY CAUSE DECOMPOSITION OF
MANGANESE DIOXIDES RESULTING IN OXIDATION & POSSIBLE IGNITION OF
HYDROCARBON VEHICLE.
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP INTO CONTAINERS. CLEAN UP RESIDUE W/
SUITABLE SOLVENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED
Ventilation:GENERAL
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING, BEFORE SMOKING
OR EATING. AVOID INGESTION.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:644F,340C
Vapor Density:NONVOL.
Spec Gravity:1.801
Evaporation Rate & Reference:NON VOLATILE
Appearance and Odor:BLACK PASTE
Percent Volatiles by Volume:0.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
EASILY OXIDIZABLE MATERIALS.
Hazardous Decomposition Products:OXIDES OF CARBON & NITROGEN, CHROMIUM
& MANGANESE COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:EPA WASTE #D-007. DISPOSE IN ACCORDANCE
W/FEDERAL, STATE, LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SCHEDULE 7 CHAMBER CLEANER, 511842
CAGE:FO738
CAGE:32510
CAGE:FO738
============= Composition/Information on Ingredients =============
Ingred Name:PHOSPHORIC ACID (SARA 313) (CERCLA)
CAS:7664-38-2
RTECS #:TB6300000
Fraction by Wt: >15%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3/3 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CITRIC ACID
CAS:77-92-9
RTECS #:GE7350000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLYOXYPROPYLENE GLYCOL; (POLYPROPOXYETHANOL)
CAS:9003-11-6
RTECS #:MD0911050
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CORROSIVE. CAUSES SEVERE BURNS
TO SKIN AND EYES. CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:OPEN CUTS AND SORES.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/FLOWING WATER FOR AT LEAST 15 MINUTES & SEE MD.
SKIN: FLUSH W/FLOWING WATER FOR 15 MINUTES. SEE MD IF IRRITATION
PERSISTS. INGESTION: GIVE MILK/WATER TO DILUTE MATERIAL & DO NOT
INDUCE V OMITING. SEE MD IMMED. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. INHALATION: REMOVE TO FRESH AIR. SUPPORT
BREATHING (GIVE OXYGEN/ARTIFICIAL RESPIRATION) .
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY OR FOG, CARBON DIOXIDE IF PRODUCT IS
INVOLVED.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . AVOID EXPOSURE TO FUMES OR VAPORS.
Unusual Fire/Explosion Hazard:USE WATER SPRAY TO COOL ADJACENT
FIRE-EXPOS CONTRS. MAY GENERATE HYDROGEN GAS IF IN CONT W/SOME
METALS. PROD WILL NOT BURN BUT MAY SPLATTER IF TEMP EXCEEDS BP.
================== Accidental Release Measures ==================
Spill Release Procedures:MOP UP AND FLUSH TO SEWER WITH PLENTY OF
WATER. FLOORS MAY BE SLIPPERY. USE CARE TO AVOID FALLS.
Neutralizing Agent:NEUTRALIZE WITH SODIUM BICARBONATE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN. DO NOT
CONTAMINATE WATER, FOOD OR FEED. AVOID ALL CONTACT.
Other Precautions:DO NOT GET IN EYES, ON SKIN OR ON CLOTHING. AVOID
BREATHING OF VAPOR OR SPRAY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST: PREFERRED. MECHANICAL (GENERAL) VENTILATION:
ACCEPTABLE.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA . IMPERVIOUS RUBBER BOOTS AND APRON.
Work Hygienic Practices:REMOVE & WASH CONTAM CLTHG BEFORE REUSE.
PRACTICE GOOD PERS HYGIENE. WASH AFTER HANDLING. SHOWER AT END OF
WORK PERIOD.
Supplemental Safety and Health
PH: 1.0 (CONCENTRATE); 3.0 (USE DILUTION).
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:17
Vapor Density:0.62
Spec Gravity:1.0936 (H*2O=1)
pH:SUPDAT
Evaporation Rate & Reference:1.0 (BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR COLORLESS THIN LIQUID, WITH CHARACTERISTIC
ACID ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:STORE IN A COOL, DRY AREA.
Hazardous Decomposition Products:HYDROGEN GAS IN CONTACT WITH SOME
METALS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL,
STATE AND FEDERAL REGULATIONS. SELL FOR SALVAGE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CIM 1000,CIM 1000 TROWEL GRADE,CIM 800 ROOFING GRADE
CAGE:GO272
CAGE:GO272
CAGE:CIMIN
============= Composition/Information on Ingredients =============
Ingred Name:ASPHALT FUMES, ASPHALT, CUTBACK ASPHALT
CAS:8052-42-4
RTECS #:CI9900000
Fraction by Wt: 20-80%
Other REC Limits:5 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:AMINE COMPOUNDS
Fraction by Wt: <10%
Ingred Name:STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 8-12%
Other REC Limits:525 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: <2%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN IRRITANT. INHALATION:
CENTRAL NERVOUS SYSTEM EFFECTS, MAY BE FATAL. INGESTION:
GASTROINTESTINAL IRRITATION, ASPIRATION MAY CAUSE CHEMICAL
PNEUMONITIS WHICH MAY BE FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: DIZZINESS, WEAKNESS, FATIGUE,
HEADACHE, UNCONSCIOUSNESS & DEATH. INGESTION: NAUSEA, VOMITING &
DIARRHEA.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MINS. SKIN: REMOVE
CONTAMINATED CLOTHING. WASH W/SOAP & WATER. DON'T USE
SOLVENTS/THINNERS TO REMOVE. ASPHALT CAN BE REMOVED W/VEGETABLE OR
MINERAL OIL. INHALATION: IF BREATHING IS DIFFICULT, GIVE OXYGEN.
IF BREATHING STOPS, APPLY ARTIFICIAL RESPIRATION. INGESTION: GIVE
WATER/MILK TO DRINK. CONSULT PHYSICIAN. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:100F
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER FOG, HALON
Fire Fighting Procedures:DON'T ENTER ANY ENCLOSED OR CONFINED FIRE
SPACE WITHOUT PROPER PROTECTIVE EQUIPMENT, INCLUDING SCBA.
Unusual Fire/Explosion Hazard:SOLVENTS CONTAINED IN PRODUCT EVAPORATE &
FORM VAPOR/FUMES WHICH CATCH FIRE/BURN W/EXPLOSIVE VIOLENCE.
INVISIBLE VAPOR SPREADS/IGNITES EASILTY. (SEE SUPP).
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. CLEAN SMALL SPILLS
USING APPROPRIATE TECHNIQUES SUCH AS ABSORBENT MATERIALS/PUMPING.
WHERE FEASIBLE & APPROPRIATE, REMOVE CONTAMINATED SOIL. FOLLOW
PRESCRIBED PROCEDURES FO R REPORTING & RESPONDING TO LARGER
RELEASES.
======================Handling and Storage ======================
Handling and Storage Precautions:USE ONLY IN WELL VENTILATED AREA. KEEP
CONTAINER CLOSED. DON'T WELD/HEAT/DRILL CONTAINER. REPLACE CAP OR
BUNG. DON'T USE/STORE NEAR IGNITION SOURCES.
Other Precautions:EMPTY CONTAINERS RETAIN HAZARDOUS EXPLOSIVE VAPOR OR
LIQUID. DON'T USE PRESSURE TO EMPTY DRUM OR EXPLOSION MAY RESULT.
AVOID AIRBORNE MISTS WHICH CAN BE INHALED OR SWALLOWED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE OSHA APPROVED TYPE C AIR SUPPLIED RESPIRATOR
IF VENTILATION IS INADEQUATE TO KEEP SOLVENT VAPORS BELOW TLV'S.
Ventilation:REQUIRED TO KEEP BELOW TLV'S.
Other Protective Equipment:PROTECTIVE MASK
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
UNUSUAL FIRE: FIRE HAZARD IS GREATER AS LIQUID TEMPERATURE RISES.
================== Physical/Chemical Properties ==================
Vapor Pres: 3
Vapor Density: 4.9
Spec Gravity:0.95-1.16
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK LIQUID W/KEROSENE ODOR
Percent Volatiles by Volume:<15
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIALS
Stability Condition to Avoid:IGNITION SOURCES
Hazardous Decomposition Products:CO, CO2, WATER VAPOR, OXIDES OF
NITROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE CONTAMINATED MATERIALS IN DISPOSABLE
CONTAINERS & DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:50/50 TIN-LEAD SOLDER
CAGE:27911
CAGE:27911
============= Composition/Information on Ingredients =============
Ingred Name:LEAD (SARA III)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 50%
OSHA PEL:0.05 MG/M3;1910.1025
ACGIH TLV:0.15 MG/M3;DUST 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
Fraction by Wt: 50%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9192
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EARLY SYMPTOMS OF LEAD INTOXICATION
ARE MOST COMMONLY GASTROINTESTINAL DISORDERS, CONSTIPATION,
WEAKNESS, INSOMA & ANEMIA. EXCESSIVE CHRONIC TIN EXPOSURE MAY CAUSE
STANNOSIS - A BENIGN PNEUMOCONIOSIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:LEAD INTOXICATION ARE MOST COMMONLY
GASTROINTESTINAL DISORDERS, CONSTIPATION, WEAKNESS, INSOMNIA &
ANEMIA. EXCESSIVE CHRONIC TIN EXPOSURE MAY CAUSE STANNOSIS - A
BENIGN PNEUMOCONIOSIS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE & PLACE INDIVIDUAL UNDER THE
CARE OF AN OCCUPATIONAL PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS (SCBA)
AND FULL PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:FILLER METAL ALONE ISN'T CONSIDERED
HAZARDOUS; HOWEVER USE IN BRAZING DUE TO NATURE OF OPERATION MAY
EXPOSE WORKERS TO HAZARDOUS SITUATIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:ANY NORMAL CLEAN-UP PROCEDURE IS APPLICABLE.
IF THE POSSIBILITY OF DUST OR FUME EXPOSURE EXISTS, WEAR NIOSH/MSHA
APPROVED RESPIRATORS.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID INGESTION. GOOD PERSONAL HYGIENE
& HOUSEKEEPING PRACTICES SHOULD BE FOLLOWED.
Other Precautions:LOCAL EXHAUST VENTILATION AND/OR RESPIRATORY
PROTECTION IS REQUIRED FOR MELTING, GRINDING, SOLDERING & OTHER
OPERATIONS WHERE EXCESSIVE AIRBORNE EXPOSURES MAY OCCUR.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR FOR TOXIC
DUST/FUME.
Ventilation:LOCAL EXHAUST AND/OR RESPIRATOR PROTECTION IS REQUIRED
Other Protective Equipment:PROTECTIVE CLOTHING IS REQUIRED IF LEAD
EXPOSURED EXCEED THE NEW OSHA PEL.
Work Hygienic Practices:GOOD PERSONAL HYGIENE & HOUSEKEEPING PRACTICES
SHOULD BE FOLLOWED
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:361-421F
Spec Gravity:8.9
Appearance and Odor:ODORLESS, SILVER-GRAY METAL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS OR HALOGEN GASES
Hazardous Decomposition Products:LEAD & TIN FUMES MAY BE EVOLVED AT
TEMPS >361-421F.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE &
LOCAL AIR POLLUTION, WATER POLLUTION & SOLID WASTE REGULATIONS.
NOTE: THIS MATERIAL MAY HAVE VALUE ON A RECYCLED BASIS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BUTANE
CAGE:S4648
CAGE:56044
CAGE:S4648
============= Composition/Information on Ingredients =============
Ingred Name:BUTANE
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:800 PPM
ACGIH TLV:800 PPM; 9596
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DNA
Explanation of Carcinogenicity:PER MSDS:DNA
Effects of Overexposure:DNA
Medical Cond Aggravated by Exposure:DNA
======================= First Aid Measures =======================
First Aid:BREATHE OXYGEN OR AIR TO VENTILATE LUNGS.
===================== Fire Fighting Measures =====================
Flash Point:-98F,-72C
Autoignition Temp:Autoignition Temp Text:NP
Lower Limits:1.8
Upper Limits:8.4
Extinguishing Media:NORMAL
Fire Fighting Procedures:INFLAMMABLE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP ROOM WELL VENTILATED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF HEAT.
Other Precautions:KEEP OUT OF FIRE & ANY SHOCK.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DNA
Ventilation:DNA
Other Protective Equipment:DNA
Work Hygienic Practices:DNA
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:G2
Boiling Pt:B.P. Text:31.1F,-0.5C
Melt/Freeze Pt:M.P/F.P Text:DNA
Decomp Temp:Decomp Text:NP
Vapor Pres:3.375@37C
Vapor Density:2.534
Spec Gravity:0.574
pH:NP
Viscosity:NP
Evaporation Rate & Reference:DNA
Solubility in Water:0.0325@20C BUNSEN CO
Appearance and Odor:COLORLESS GAS, NO ODOR
Percent Volatiles by Volume:NP
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
DNA
Stability Condition to Avoid:UNSTABLE @TEMPERATURES OVER 435C.
Hazardous Decomposition Products:DNA
Conditions to Avoid Polymerization:DNA
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP ROOM WELL VENTILATED.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LEADERTITE NON-ASBESTOS-FILLED SPIRAL-WOUND GASKET
CAGE:0X693
CAGE:0X693
============= Composition/Information on Ingredients =============
Ingred Name:GRAPHITE; (GRAPHITE (NATURAL))
CAS:7782-42-5
RTECS #:MD9659600
OSHA PEL:15 MPPCF
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:CHLORITE
CAS:66588-14-5
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACRYLONITRILE-BUTADIENE-STYRENE TERPOLYMER; (ACRYLONITRILE
LATEX)
CAS:9003-56-9
RTECS #:AT6970000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:GRAPHITE/CHLORITE FIBERS ARE CONFINED
AND GENERALLY DO NOT GENERATE ANY DUST. PROLONGED OR REPEATED
BREATHING OF DUST CAN RESULT IN PULMONARY DISEASE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:EMPHYSEMA, ASTHMA.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . EYES:IMMEDIATELY FLUSH
W/POTABLE WATER FOR A MINIMUM OF 15 MINUTES, SEEK ASSISTANCE FROM
MD. SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD .
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE . WILL NOT
SUPPORT COMBUSTION.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
================== Accidental Release Measures ==================
Spill Release Procedures:FOLLOW GOOD HOUSEKEEPING PROCEDURES. VACUUM &
WET MOP LOOSE PARTICLES &/OR DUST.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT GRIND OR PULVERIZE. PREVENT
DUST ESCAPE INTO ATMOSPHERE. DO NOT BREATHE DUST.
Other Precautions:THE INGREDIENTS ARE CONFINED BETWEEN MOLAR PILES.
METALS ARE SHIPPED IN A STABLE & INERT CONDITION. HAZARDOUS FUMES
OF COMPONENT ELEMENTS MAY ONLY BE GENERATED BY PROCESSING WHICH
REDUCES MATERIALS TO AN AIR CONTAMINANT FORM.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR FOR NUISANCE DUST.
Ventilation:LOCAL EXHAUST:PREFERRED.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Supplemental Safety and Health
APPEAR/ODOR:WITHOUT METALLIC RETAINING RINGS; ODORLESS.
================== Physical/Chemical Properties ==================
Spec Gravity:1.68 (H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:ALTERNATING METALLIC/NON-METALLIC PLIES
(SILVER/GREY IN COLOR) WITH/ (SUPDAT)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . DISPOSE OF IN AN APPROPRIATE LANDFILL. CHECK LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CITRIC ACID, ANHYDROUS, FCC USP
CAGE:8G980
CAGE:8G980
============= Composition/Information on Ingredients =============
Ingred Name:CITRIC ACID
CAS:77-92-9
RTECS #:GE7350000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: SLIGHT IRRITATION TO SKIN,
EYES. CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH POTABLE WATER FOR AT LEAST 15 MINUTES. SEE
MD . SKIN: FLUSH WITH COPIOUS AMOUNTS OF WATER. SEE MD . INHAL:
REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE OXYGEN OR ARTIFICIA L
RESPIRATION) . INGEST: CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN BY VACUUM OR BROOM SWEEPING AND REMOVE
TO DISPOSAL CONTAINER.
Neutralizing Agent:COVER W/SODA ASH/SODIUM BICARBONATE TO NEUTRALIZE.
MIX & ADD WATER IF NEC.
======================Handling and Storage ======================
Handling and Storage Precautions:NORMAL GMP HANDLING AND STORAGE
PROCEDURES. STORE IN SEALED CONTAINER TO PREVENT DUSTING.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED DUST MASK APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:GOOD LOCAL VENTILATION.
Other Protective Equipment:EYES, NOSE, MOUTH AND EXPOSED SKIN AREAS
SHOULD BE COVERED AS NEEDED TO HELP PREVENT IRRITATION.
Work Hygienic Practices:NORMAL GOOD MANUFACTURING AND HOUSEKEEPING
PROCEDURES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Solubility in Water:162G/100ML @ 25C
Appearance and Odor:ODORLESS, FREE FLOWING, WHITE CRYSTALLINE MATERIAL,
WITH A STRONG ACID TASTE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AQUEOUS REACTION WITH CAUSTIC CAN CREATE HEAT (STRONG EXOTHERM).
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:SCOOP UP SLURRY OR WASH DOWN DRAIN WITH EXCESS
WATER. DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:26-00701-06SULFURIC ACID ELECT. 1.835BDY
Preparer's Name:GENE TURNER
CAGE:LO577
CAGE:6Z690
CAGE:LO577
============= Composition/Information on Ingredients =============
Ingred Name:SULFURIC ACID (SARA III)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 93.2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RAT LD50 IS 2140 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITATION, CORNEAL BURNS
CONJUNCTIVITIS. SKIN SEVERE BURNS, NECROSIS, ULCERATION.
INHALATION: IRRITATION, BURNS TO RESPIRATORY TRACT, PULMONARY
EDEMA. LC50 = 20-60 MG/M3. INGESTED: IRRITATION, B URNS TO
GASTROINTESTINAL TRACT. HARMFULIF SWALLOWED. CHRONIC: EROSION OF
TEETH, LESIONS, BRONCHITIS
Explanation of Carcinogenicity:NOT LISTED AS A CARCINOGEN BY IARC, NTP,
OSHA, ACGIH.
Effects of Overexposure:EYE: IRRITATION, BURNS, BLINDNESS. SKIN: SEVERE
BURNS, NECROSIS, ULCERS. INHALATION: IRRITATION, BURNS TO
RESPIRATORY TRACT. COUGH, DISCOMFORT, DIFFICULTY IN BREATHING,
SHORTNESS OF BREATH. ACUTE EXPO SURE MAY CAUSE PULMONARY EDEMA.
INGESTIOM: GASTROINTESTINAL IRRITATION, BURNS. CAN BE FATAL IF
SWALLOWED.
Medical Cond Aggravated by Exposure:NONE GIVEN BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER 15 MINUTES, HOLD LIDS OPEN. SKIN: WASH
WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER
BEFORE REUSE. INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING IF
NECESSAR Y. INGESTION: DO NOT INDUCE VOMITING. GIVE 2 LARGE GLASSES
OF MILK OR WATER . GET IMMEDIATE MEDICAL CARE. GIVE NOTHING BY
MOUTH IF UNCONSCIOUS. IF IRRITATION PERSISTS OR IS SEVERE. SEE A
DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:WILL NOT BURN
Extinguishing Media:USE WATER SPRAY, DRY CHEMICAL, CARBON DIOXIDE FOR
FIRES ADJACENT TO NON-LEAKING TANKS AND OTHER CONTAINERS.
Fire Fighting Procedures:WEAR NIOSH-APPROVED SELF CONTAINED BREATHING
APPARATUS WITH FULL FACEPIECE AND FULL PROTECTIVE CLOTHING. COOL
NON-LEAKING FIRE-EXPOSED CONTAINERS WITH WATER SPR
Unusual Fire/Explosion Hazard:FLAMMABLE AND POTENTIALLY EXPLOSIVE
HYDROGEN GAS CAN BE GENERATED INSIDE METAL DRUMS AND STORAGE TANKS.
CONCENTRATED ACID CAN IGNITE COMBUSTIBLE MATERIAL.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILL: CAUTIOUSLY DILUTE WITH PLENTY OF
WATER AND NEUTRALIZE. LARGE SPILL: EVACUATE UNPROTECTED PEOPLE.
CONTAIN ACID BY DIKING SPILL WITH SOIL, ETC. RECOVER ACID IF
POSSIBLE. KEEP OUT OF SEWERS. ANY RELEASE TO ENVIRON. MAY BE
SUBJECTTO REPORT.
Neutralizing Agent:SODA ASH OR LIME
======================Handling and Storage ======================
Handling and Storage Precautions:'EMPTY' CONTAINERS MAY CONTAIN RESIDUE
OR VAPOR. TREAT THEM WITH THE RESPECT DUE FULL ONES. KEEP CONTAINER
CLOSED. DO NOT ADD WATER TO ACID IN CONT.
Other Precautions:LOOSEN CLOSURE CAREFULLY. WHEN CARRYING GLASS
BOTTLES, USE RUBBER PROTECTIVE ENCLOSURES. IF STORED IN METAL,
CONTAINER MAY CONTAIN EXPLOSIVE HYDROGEN GAS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR EXPOSURE ABOVE PEL/TLV AND UP TO 25 MG/M3,
USE ANY POWERED AIR PURIFYING RESPIRATOR WITH HIGH EFFICIENCY
PARTICULATE FILTER AND ACID GAS CARTRIDGE. FOR ALTERNATES AND FOR
HIGHER CONCENTRATIONS SEE NIOSH/OSHA POCKET GUIDE TO CHEM HAZARDS
Ventilation:SUFFICIENT TO REDUCE VAPOR AND ACID MIST TO PERMISSABLE
LEVELS. MAY REQUIRE LOCAL EXHAUST FOR PACKAGING AND LOADING AREA
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER, HARD
HAT, ACID RESISTANT APRON, BOOTS. BETTER YET, WEAR ACID SUIT.
NEUTRALIZE EQUIP.
Work Hygienic Practices:AVOID BREATHING VAPORS OR MISTS. MINIMIZE SKIN
CONTACT. WASH WITH SOAP AND WATER BEFORE EATING, DRINKING, SMOKING,
ETC.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:535F,279C
Vapor Pres:< 0.3
Vapor Density:3.4
Spec Gravity:1.835
pH:< 1
Evaporation Rate & Reference:< 1 (N-BUTYL ACETATE = 1)
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS TO LIGHT BROWN, CLEAR TO TURBID, OILY,
ODORLESS LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NITRO COMPOUNDS, CARBIDES, DIENES, ALCOHOLS, OXIDIZING AGENTS,
ALDEHYDES, ALLYLS, METALS
Stability Condition to Avoid:HIGH HEAT, MOISTURE
Hazardous Decomposition Products:OXIDES OF SULFUR, HYDROGEN SULFIDE,
HYDROGEN GAS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL,
STATE, AND LOCAL REGULATIONS. MANUFACTURER MAKES NO SUGGESTIONS AS
TO METHOD OF DISPOSAL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:5536 METHANOL
Resp. Party Other MSDS Num.:LABCO SCIENTIFIC DIV OK 73104
CAGE:DO803
CAGE:DO803
CAGE:1A109
============= Composition/Information on Ingredients =============
Ingred Name:METHANOL (METHYL ALCOHOL), COLUMBIAN SPIRITS *97-4*
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 90-100%
Other REC Limits:200 PPM
OSHA PEL:200 PPM
ACGIH TLV:200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 5628 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION:
HARMFUL/HEADACHE/NAUSEA/VOMITING/DIZZINESS/NARCOSIS/RESPIRATORY
FAILURE/LOW BLOOD PRESSURE/CNS DEPRESSION/FATAL. SKIN:
IRRITATION/DERMATITIS. EYE: IRRITATION/CORNEAL DAMAGE. INGESTION:
HAR
MFUL/BLINDNESS/HEADACHE/NAUSEA/VOMITING/DIZZINESS/GASTROINTESTINAL
IRRITATION/CNS DEPRESSION/HEARING LOSS/FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: KIDNEY/LIVER DAMAGE. SKIN:
IRRITATION & DERMATITIS. EYES: IRRITATION & CORNEAL DAMAGE.
INGESTION: HARMFUL, BLINDNESS, HEADACHE, NAUSEA, VOMITING,
DIZZINESS, GASTROINTESTINAL IRRITATION, CN S DEPRESSION, HEARING
LOSS, & FATAL. POISON, CANNOT BE MADE NON-POISONOUS.
Medical Cond Aggravated by Exposure:EYE, SKIN, LIVER OR KIDNEY
DISORDERS.
======================= First Aid Measures =======================
First Aid:INGESTION: IF CONSCIOUS, DRINK PLENTY OF WATER. INDUCE
VOMITING. INHALATION: REMOVE TO FRESH AIR. GIVE CPR OR OXYGEN IF
NEEDED. SKIN/EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS.
OBTAIN MEDICAL ATTENTION IN ALL CASES. POISON, CANNOT BE MADE
NON-POISONOUS.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:54F
Lower Limits:6%
Upper Limits:36%
Extinguishing Media:ALCOHOL FOAM, DRY CHEMICAL, OR CO2. WATER MAY BE
INEFFECTIVE. USE WATER SPRAY TO REDUCE VAPORS.
Fire Fighting Procedures:WEAR PROTECTIVE EQUIP & SCBA W/FULL FACEPIECE
OPERATED IN POSITIVE PRESSURE MODE. SAFELY, MOVE CONTAINERS. USE
WATER TO KEEP FIRE EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:VAPORS MAY FLOW TO IGNITION
SOURCES/FLASHBACK. CLOSED CONTAINERS EXPOSED TO HEAT MAY EXPLODE.
BURNS W/CLEAR, ALMOST INVISIBLE FLAME. AUTO-IGNITION TEMP: 867F.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIP. SHUT OFF IGNITION
SOURCES. SAFELY, STOP LEAK. USE WATER SPRAY TO REDUCE VAPORS. TAKE
UP W/SAND OR OTHER NON-COMBUSTIBLE ABSORBENT MATERIAL & PLACE INTO
CONTAINER FOR LATER DISPO SAL. FLUSH AREA W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN A COOL, DRY, WELL-VENTILATED, FLAMMABLE LIQUID STORAGE AREA.
BOND/GROUND CONTAINERS WHEN TRANSFERRING LIQUID.
Other Precautions:AVOID CONTACT W/EYES, SKIN, CLOTHING, & BREATHING
VAPORS. KEEP OUT OF REACH OF CHILDREN. DON'T SMOKE. CONTACT
W/STRONG OXIDIZERS MAY CAUSE FIRE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AT CONCENTRATIONS >200 PPM, USE A SELF-CONTAINED
BREATHING APPARATUS.
Ventilation:PROVIDE GENERAL/LOCAL EXHAUST VENTILATION TO KEEP <TLV.
Other Protective Equipment:UNIFORM, PROTECTIVE SUIT
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:149F
Melt/Freeze Pt:M.P/F.P Text:-144F
Vapor Pres:96
Vapor Density:1.11
Spec Gravity:0.79
Evaporation Rate & Reference:(BU AC = 1 ): 4.6
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID W/PUNGENT ODOR.
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ACIDS, ZINC, ALUMINUM, & MAGNESIUM.
Stability Condition to Avoid:HEAT, FLAME, FLARES, SMOKING OR OTHER
SOURCES OF IGNITION.
Hazardous Decomposition Products:CO, CO2, & FORMALDEHYDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. EPA HAZARDOUS WASTE NUMBER: U154. FLAMMABLE
LIQUID. UN1230.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:124 8160 EKTACOLOR RA 100 DEVELOPER REPLENISHER, 12/55 RA-4
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 95-100%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM CARBONATE
CAS:584-08-7
RTECS #:TS7750000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred
Name:4-(N-ETHYL-N-2-METHANESULFONYLAMINOETHYL)-2-METHYLPHENYLENEDIA
MINE
CAS:25646-71-3
RTECS #:PB0431000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM CHLORIDE
CAS:7447-40-7
RTECS #:TS8050000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIETHYLHYDROXYLAMINE
CAS:3710-84-7
RTECS #:NC3500000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): NOT GIVEN
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. EYE CONTACT MAY CAUSE TRANSIENT
IRRITATION. SKIN CONTACT MAY CAUSE ALLERGIC SKIN REACTION. EXPECTED
TO BE A LOW INGESTION HAZARD. MAY C AUSE IRRITATION OF THE
GASTROINTESTINALTRACT.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION, ALLERGIC SKIN REACTION, GI
TRACT IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH WATER FOR 15 MINUTES. GET
MEDICAL ATTENTION ASAP. INHALATION: MOVE TO FRESH AIR. TREAT
SYMPTOMATICALLY. GET MEDICAL ATTENTION. SKIN: IMMEDIATELY REMOVE
CONTAMINATED CLOTHI NG AND WASH WITH SOAP AND WATER. GET MEDICAL
ATTENTION. INGESTION: DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL
ATTENTION. NEVER GIVE ANYTHING BY MOUTH IF UNCONSCIOUS..
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:NONFLAMMABLE. USE EXTINGUISHING MEDIA SUITABLE FOR
SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOHNTS OF WATER.
ABSORB LARGE SPILLS WITH VERMICULITE OR OTHER INERT MATERIAL, THEN
PLACE IN CONTAINER FOR CHEMICAL WASTE. PREVENT RUNOFF FROM ENTERING
DRAINS, SEWERS, OR ST REAMS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PROLONGED OR REPEATED BREATHING
OF MIST OR VAPOR. AVOID CONTACT WITH EYES, SKIN & CLOTHING. USE
WITH ADEQUATE VENTILATION. KEEP CONTAINER CLOSED
Other Precautions:THE ROUTINE USE OF A NONALKALINE (ACID) TYPE OF HAND
CLEANER AND REGULAR CLEANING OF WORKING SURFACES WILL HELP MINIMIZE
THE POSSIBILITY OF A SKIN REACTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION (10 AIR CHANGES/HOUR) SHOULD BE
USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS.
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER, WASHING
FACILITIES. WEAR PROTECTIVE CLOTHING APPROPRIATE FOR THE RISK OF
EXPOSURE.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER. THIS ENTRY FOR WORKING SOLUTION.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Decomp Temp:Decomp Text:NOT GIVEN
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:NOT GIVEN
pH:10.8
Viscosity:NOT GIVEN
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:YELLOW LIQUID. NO ODOR.
Percent Volatiles by Volume:95-100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE WITH COMMON MATERIALS AND CONTAMINANTS WITH WHICH THE MATERIAL MAY
REASONABLY COME INTO CONTACT.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTRACT WITH A LICENSED CHEMICAL DISPOSAL
AGENCY. DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT TO
FEDERAL, STATE, OR LOCAL LAWS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:2164584
CAGE:7N876
CAGE:7N876
CAGE:52122
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL (EXPOSURE REGULATED AS 'OIL MIST')
CAS:8012-95-1
RTECS #:PY8030000
Fraction by Wt: 99%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3/10 STEL;9192
Ingred Name:DITERTIARY BUTYL PARACRESOL
Fraction by Wt: 0.42%
ACGIH TLV:N.K
Ingred Name:RUST INHIBITOR.
Fraction by Wt: 0.08%
Ingred Name:ANTIOXIDANT
Fraction by Wt: 0.08%
===================== Hazards Identification =====================
Effects of Overexposure:EYES, SKIN, INHAL-MILD IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES - FLUSH COPIOUSLY WITH WATER 15 MINUTES. SKIN - WASH
WITH SOAP AND WATER. INHAL - REMOVE FROM EXPOSURE. INGEST - DO NOT
INDUCE VOMITING, OBTAIN MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:394F/202C
Lower Limits:0.6
Upper Limits:7.0
Extinguishing Media:WATER, DRY CHEM, CARBON DIOXIDE, FOAM.
Fire Fighting Procedures:USE NIOSH-APPROVED SELF-CONTAINED BREATHING
APPARATUS.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIM ALL SOURCES OF IGNITION. VENT AREA, AVOID
BREATHING VAPORS. COVER WITH ABSORBENT MATERIAL. COLLECT MIXTUE AND
PLACE IN A CLOSED CONTAINER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV EXCEED - NIOSH APPROVED MIST CARTRIDGE
RESPIRATOR.
Ventilation:LOCAL EXHAUSE OR GENERAL DILUTION VEN
Supplemental Safety and Health
IBM, OIL, NO 6 LUBE.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:598F/316C
Vapor Pres:20
Vapor Density:0.87
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORLESS, OILY LIQUID; MILD ODOR.
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, OXIDIZERS
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAMES.
Hazardous Decomposition Products:CARBON MONOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:USE CERTIFIED VENDOR FOR DISPOSAL IN A SECURE
LANDFILL OR INCINERATION.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FREON 502 REFRIGERANT
Preparer's Name:W J BROCK
CAGE:25827
CAGE:25827
============= Composition/Information on Ingredients =============
Ingred Name:ETHANE, CHLOROPENTAFLUORO ("FREON" 115) (SARA 313)
CAS:76-15-3
RTECS #:KH7877500
Fraction by Wt: 51.2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ozone Depleting Chemical:1
Ingred Name:METHANE, CHLORODIFLUORO ("FREON" 22)
CAS:75-45-6
RTECS #:PA6390000
Fraction by Wt: 48.8%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ozone Depleting Chemical:2
===================== Hazards Identification =====================
LD50 LC50 Mixture:FREON "115" 800,000 PPM/"22" 220,000 PPM
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:OVEREXPOS BY INHAL MAY INCLUDE
DISCOMFORT- NAUSEA/HEADACHE/WEAKNESS/TEMP NERV SYS DEPRESS
W/ANESTHETIC EFFECTS LIKE DIZZINESS/CONFUSION/INCOORDINATION/LOSS
OF CONSCIOUSNESS OR W/GROSS OVEREXPOS (>20%) , POSS TEMP ALTERATION
OF THE HEART'S ELECTRICAL ACTIVITY W/IRREG
PULSE/PALPITATIONS/INADEQ CIRCULATION. MISUSE: DEATH.#
Explanation of Carcinogenicity:N/K #INDIVIDUALS W/PREEXISTING DISEASES
OF THE CENTRAL NERV/CARDIO SYS MAY HAVE INCREASED SUSCEPTIBILITY TO
##
Effects of Overexposure:##TOXICITY EXCESSIVE EXPOSURES. CARDIAC
SENSITIZATION WAS OBSERVED IN BEAGLE DOGS EXPOSED TO CONCENTRATIONS
OF 15% TO 25% "FREON" 115. VAPOR REDUCES OXYGEN AVAILABLE FOR
BREATHING & IS HEAVIER THAN AI R. SKIN CONTACT WITH THE LIQUID CAN
CAUSE FROSTBITE. "FREON" 22-TOXICITY IN ANIMALS BY INHAL TO CONC
RANGING FROM###
Medical Cond Aggravated by Exposure:N/K ###5 TO 70% INCLUDE EFFECTS ON
THE CENTRAL NERV SYS/LIVER/LUNGS/KIDNEYS/SPLEEN/CARDIAC
SENSITIZATION/DECREASED BODY WEIGHT GAIN/PARTIAL ANESTHESIA.
INCREASE OF TUMORS IN MALE RATS AT CONC OF####
======================= First Aid Measures =======================
First Aid:INHAL: IMMED GET FRESH AIR. KEEP CALM. IF BREATH STOP, GIVE
ARTIF RESP/IF DIFFICULT, GIVE OXYGEN. CALL DR. SKIN: CLEAN SKIN
AFTER USE. EYE: IMMED FLUSH W/WATER. CALL DR. "NOTES TO PHYSICIAN":
BECAUSE OF POSSIBLE DISTURBANCES OF CARDIAC RHYTHM, CATECHOLAMINE
DRUGS, SUCH AS EPINEPHRINE, SHOULD BE USED WITH SPECIAL CAUTION
ONLY IN SITUATIONS OF EMERGENCY LIFE SUPPORT.
===================== Fire Fighting Measures =====================
Flash Point:WILL NOT BURN
Extinguishing Media:AS APPROPRIATE FOR COMBUSTIBLES IN AREA.
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS IS REQUIRED
IF CYLINDERS RUPTURE OR RELEASE UNDER FIRE CONDITIONS.
Unusual Fire/Explosion Hazard:CYLINDERS ARE EQUIPPED WITH TEMPERATURE
AND PRESSURE RELIEF DEVICES BUT STILL MAY RUPTURE UNDER FIRE
CONDITIONS. DECOMPOSITION MAY OCCUR.
================== Accidental Release Measures ==================
Spill Release Procedures:REVIEW FIRE & EXPLOSION HAZARDS & SAFETY
PRECAUTIONS BEFORE PROCEEDING WITH CLEAN-UP. USE APPROPRIATE
PERSONAL PROTECTIVE EQUIPMENT DURING CLEANING. VENT AREA-ESPEC LOW
PLACES WHERE HEAVY VAPORS MIGHT COLLECT. RMV OPEN FLAMES. USE SCBA
FORLG SPILLS.
======================Handling and Storage ======================
Handling and Storage Precautions:CLEAN, DRY AREA. DO NOT HEAT ABOVE 125
DEGREES F.
Other Precautions:N/K ####50,000 PPM. SLIGHT BUT SIGNIFICANT INCREASE
IN DEVELOPMENTAL TOXICITY (EYE MALFORMATIONS, DECREASED FETAL
WEIGHTS) OBSERVED IN OFFSPRING OF RATS EXPOSED TO HIGH CONC (50,000
PPM) OF FC-22. HOW EVER NO INDICATION OF ADVERSE#####
============= Exposure Controls/Personal Protection =============
Ventilation:NORM VENT-GEN ADEQ. LOCAL EXHAUST SHOULD BE USED WHEN LARGE
AMOUNTS ARE RELEASED. MECH VENT SHOULD BE USED IN LOW PLACES
Other Protective Equipment:SELF-CONTAINED BREATHING APPARATUS IS
REQUIRED IF A SPILL OR RELEASE OCCURS.
Supplemental Safety and Health
#####EFFECTS ON FEMALE REPRODUCTIVE PERFORMANCE AT CONCENTRATIONS UP TO
50,000 PPM.
================== Physical/Chemical Properties ==================
HCC:G3
Boiling Pt:B.P. Text:-50F,-45C
Vapor Pres:169 PSIA
Vapor Density:3.92 @ 25C
Spec Gravity:1.22
pH:NEUTRL
Evaporation Rate & Reference:> 1 (CCL4 = 1.0)
Solubility in Water:0.15 WT% AT 25 C
Appearance and Odor:CLEAR, COLORLESS LIQUIDFIED GAS WITH SLIGHT
ETHEREAL ODOR.
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALI OR ALKALINE EARTH METALS - POWDERED AL, ZN, BE, ETC.
Stability Condition to Avoid:OPEN FLAMES AND HIGH TEMPERATURES.
Hazardous Decomposition Products:FREON 502 REFRIGERANT CAN BE DECOMP BY
HIGH TEMP (OPEN FLAMES/GLOW METAL SURFACES, ETC) FORMING
HYDROCHLORIC AND
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY WITH FEDERAL, STATE AND LOCAL
REGULATIONS. REMOVE TO A PERMITTED WASTE DISPOSAL FACILITY OR
RECLAIM BY DISTILLATION.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: 11592
Cage: 6Z384
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 70878
Box: 1974
Cage: 6Z384
Box: 125
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:PETROLEUM DISTILLATE:INHALATION:IRRITATION OF EYES,
NOSE AND THROAT. INGESTION:NAUSEA, VOMIT. LARGE AMOUNTS LEAD TO SYMPTOMS OF
CENTRAL NERVOUS SYSTEM DEPRESSON. SKIN:DERMATITIS. EYE:IRRITATION.
CHRONIC:CAN CAUSE IRRITATION TO EYES, NOSE AND THROAT ON PROLONGED EXPOSURE
AND/OR DIRECT CONTACT. (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ:IF SWALLOWED, MAY CAUSE CENTRAL
NERVOUS SYSTEM DEPRESSION.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES:IMMED FLUSH W/LG QTYS OF WATER FOR @ LEAST 15 MINS & CALL
PHYS. SKIN:REMOVE EXCESS W/CLOTH OR PAPER. WASH THORO W/SOAP & WATER.
INHAL:REMOVE VICTIM TO FRESH AIR. INGEST:CALL PHYS IMMED. DO NOT IN DUCE
VOMIT. (VOMIT MAY CAUSE ASPIR INTOLUNGS RESULTING IN CHEMICAL PNEUMONIA).
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: TRANSFER BULK OF MIXTURE INTO ANOTHER CNTNR. ABSORB
RESIDUE W/INERT MATL SUCH AS EARTH, SAND, OR VERMICULITE. SWEEP UP &
DISPOSE AS SOLID WASTE I/A/W LOCAL, STATE, AND FEDERAL REGULATIONS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE FEDERAL,
STATE AND LOCAL REGULATIONS.
Handling And Storage Precautions: KEEP CONTAINER CLOSED UNTIL READY TO USE.
AVOID SKIN AND EYE CONTACT. DO NOT SWALLOW. KEEP OUT OF REACH OF CHILDREN!!!
Other Precautions: IF USED IN APPLIC WHERE MIST MAY BE GENERATED, OBSERVE
TWA/PEL OF 5 MG/M3 FOR MINERAL OIL MIST (OSHA & ACGIH).
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: COC
Flash Point Text: >216F,>102C
Extinguishing Media: DRY CHEMICAL OR WATERFOG/CO*2 OR FOAM OR SAND/EARTH. CLSD
CNTNRS EXPOS TO FIRE MAY BE COOLED WITH WATER.
Fire Fighting Procedures: DENSE SMOKE. USE NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: DENSE SMOKE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE. NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN (FP N).
Ventilation: NONE.
Other Protective Equipment: ANSI APPRVD EMERGENCY EYE WASH & DELUGE SHOWER (FP
N).
Work Hygienic Practices: WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health: USERS OF "L" VERSION OF SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). HAZ DECOMP PROD:DEPENDING UPON DECOMP CNDTNS.
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 0.87 (WATER =1)
Solubility in Water: NEGLIGIBLE @ 25C
Appearance and Odor: BLUE OIL LIQUID, MINERAL OIL ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: STRONG OXIDIZERS SUCH AS HYDROGEN PEROXIDE, BROMINE, AND
CHROMIC ACID.
Hazardous Decomposition Products: CARBON MONOXIDE & CARBON DIOXIDE FROM
BURNING. OXIDES OF SULFUR & NITROGEN, SULFUR DIOXIDE/HYDROGEN SULFIDE,
(SUPDAT)
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: 11592
Cage: 6Z384
Company Name: WITCO
Street: 29111 MILFORD RD
PO Box: 125
Zipcode: 48165
Label Required IND: Y
Date Of Label Review: 02/23/1996
Status Code: C
Label Date: 02/23/1996
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE:PETROLEUM
DISTILLATE:INHALATION:IRRITATION OF EYES, NOSE AND THROAT. INGESTION:NAUSEA,
VOMIT. LARGE AMOUNTS LEAD TO SYMPTOMS OF CENTRAL NERVOUS SYSTEM DEPRESSON.
SKIN:DERMATITIS. EY E:IRRITATION. CHRONIC:CAN CAUSE IRRITATION TO EYES, NOSE
AND THROAT ON PROLONGED EXPOSURE AND/OR DIRECT CONTACT. IF SWALLOWED, MAY
CAUSE CENTRAL NERVOUS SYSTEM DEPRESSION.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CORROSION RESISTANT COATING, GRAY 1706
CAGE:76381
CAGE:76381
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLOROPRENE
CAS:9010-98-4
RTECS #:EI9640000
Ingred Name:CHLORINATED NATURAL RUBBER
OSHA PEL:NA
ACGIH TLV:NA
Ingred Name:PHENOLIC RESIN BLEND
OSHA PEL:NA
ACGIH TLV:NA
Ingred Name:FIBER BLEND
OSHA PEL:NA
ACGIH TLV:NA
Ingred Name:NAPHTA (PETROLEUM SPIRITS OR BENZIN)
CAS:8030-30-6
RTECS #:DE3030000
Fraction by Wt: 2%
OSHA PEL:100 PPM
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 40%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL N-AMYL KETONE
CAS:110-43-0
RTECS #:MJ5075000
Fraction by Wt: 12%
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9192
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:INHAL: OVEREXPOSURE TO XYLENE VAPORS
MAY CAUSE RESPIRATORY IRRITATION, NERVOUS SYSTEM IMPAIRMENT, LIVER
DAMAGE, KIDNEY DAMAGE, BLOOD CHANGES, LUNG DAMAGE, BRAIN
DISORDERS & SUDDEN HEART ATTACK.
Effects of Overexposure:EYE: TEARING, BURNINGSENSATION & BLURRED
VISION. SKIN: IRRITATION CRACKING &
DEFATTING OF SKININHAL:
DIZZINESS, LIGHT HEADEDNESS, WEAK NESS & HEADACHES.INGST: DIGESTIVE
SYSTEM IRRITATION AND NAUSEA.
======================= First Aid Measures =======================
First Aid:EYE: IMMEDIATELY FLUSH W/PLENTY OF WATER FOR 10 MINS., CALL A
PHYSICIAN. SKIN: WASH AREA W/SOAP & WATER, REMOVE
CONTAMINATED CLOTHING. INHAL: MOVE TO FRESH AIR,
RESTORE BREATH ING AS NECESSARY, CALL A PHYSICIAN.INGST: DO NOT
INDUCE VOMITING. GIVE TWO GLASSES OF MILK/WATER TO DRINK, CALL A
PHYSICIAN IMMMED.,IF VOMITING OCCURS PUT HEAD BETWN KNEES TO PREVNT
LUNGS ASPIR.
===================== Fire Fighting Measures =====================
Flash Point:71F/21.67C
Lower Limits:1.0
Upper Limits:6.0
Extinguishing Media:CO2, FOAM, DRY CHEMICALS
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS WHEN
FIGHTING FIRES INVOLVING THIS MATL.
Unusual Fire/Explosion Hazard:FLAMMABLE, OVERHEATED, CLOSED CONTAINERS
ADJACENT TO FIRE COULD EXPLODE DUE TO PRESSURE BUILD UP.
================== Accidental Release Measures ==================
Spill Release Procedures:EXTINGUISH ALL IGNITION SOURCES. COLLECT
SPILLED MATERIAL, CLEAN UP RESIDUE AND STORE IN CLOSED METAL
CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS,FLAMES.
KEEP CONTAINERCLOSED WHEN NOT IN USE. VENTILATE W/ENOUGH AIR TO
REMOVE VAPORS AND PREVENT BUILD UP.
Other Precautions:VAPORS RELEASED BY THIS PRODUCT CAN BE EASILY
IGNITED. AVOID PROLONGED BREATHINGOF VAPORS. PREVENT CONTACT WITH
EYES AND SKIN. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Ventilation:LOCAL EXHAUST VENTILATION
Other Protective Equipment:UTILIZE PERSONAL PROTECTION EQUIPMENT WHEN
HANDLING THIS PRODUCT.
Work Hygienic Practices:WASH HANDS THOROUGHLY BEFORE SMOKING OR EATING.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:275F
Decomp Temp:Decomp Text:NA
Vapor Pres:6 MM
Vapor Density:3.6
Spec Gravity:1.0
pH:NA
Viscosity:SEE BELOW
Evaporation Rate & Reference:9.2
Solubility in Water:VERY LOW
Appearance and Odor:GRAY VISCOUS LIQUID WITH STRONG SOLVENT ODOR
Percent Volatiles by Volume:69
Corrosion Rate:NA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NK
Hazardous Decomposition Products:CO, C02, OXIDES OF LEAD AND
CHLORINATED DECOMPOSITION PROD.
==================== Disposal Considerations ====================
Waste Disposal Methods:COMMERICAL INCINERATION W/DESTRUCTION & REMOVAL
EFFICIENCY >99.99% OR RECLAMATION IS PREFERRED, OTHERWISE
DISPOSE IN ACCORDANCE WITH APPLICABLE REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DEOX IT-D5, D5S-6
Preparer's Name:MARK K. LOHKEMPER
CAGE:55403
CAGE:55403
============= Composition/Information on Ingredients =============
Ingred Name:ING 7:15 MIN. SKIN: CLEANSE AFFECTED AREA(S) WITH MILD SOAP
AND WATER. IF IRRIT PERSISTS SEEK MED ATTN. INGEST: (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: DO NOT INDUCE VOMITING, KEEP PERSON WARM, QUIET AND
GET MED ATTN. ASPIRATION OF MATL INTO LUNGS DUE TO (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: VOMIT CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE
FATAL.
RTECS #:9999999ZZ
Ingred Name:SPILL PRO: BY VENTILATION, CLEAN UP OILY RESIDUE WITH ANY
STANDARD DISPOSAL SOAP OR DETERGENT SOLUTION.
RTECS #:9999999ZZ
Ingred Name:VENT: LOCATIONS MUST BE USED.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: USE ONLY AS DIRECTED.
RTECS #:9999999ZZ
Ingred Name:MINERAL SPIRITS; (PETROLEUM NAPHTHA). FL PT: 40C, 104F.
CAS:64742-88-7
Fraction by Wt: 75%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:ETHANE, 1,1,1-DIFLUORO-; (DIFLUOROETHANE)
CAS:75-37-6
RTECS #:KI1410000
Fraction by Wt: 20%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DEOXIT D100L LIQUID
Fraction by Wt: 5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:EFTS OF OVEREXP: DERMATITIS. ORAL: NO SPECIFIC INTERVENTION
IS INDICATED AS THE CMPNDS IS NOT LIKELY TO BE (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: HAZARDOUS BY INGESTION. HOWEVER, INGESTION OF
EXCESSIVE QUANTITIES CAN CAUSE GI IRRIT, NAUSEA, VOMITING, (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: DIARRHEA. ASPIRATION OF MATERIAL INTO THE LUNGS CAN
CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: FOR DIRECT CNTCT, HOLD EYELIDS APART &
FLUSH THE AFFECTED EYES(S) WITH CLEAN WATER FOR AT LEAST (ING 8)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ING 2:INHAL: VAP IS HVR/AIR & CAN
CAUSE SUFFOCATION BY REDUCING OXYGEN AVAIL FOR BRTHG. BRTHG HIGH
CONC OF VAP MAY CAUSE LT-HEAD, DIZZ, SHORTNESS OF BREATH, & MAY
LEAD TO NARCOSIS, CARDIAC IRREGULARIT IES, UNCONSCIOUSNESS OR
DEATH. ING 1: INHAL:LOW DEGREE OF TOXICITY, BUT BRTHG HIGH CONC OF
VAPS OR (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:MISTS MAY CAUSE IRRIT OF THE NOSE &
THROAT & SIGNS OF NERV SYS DEPRESS (E.G., HDCH, DROWSINESS, DIZZ) &
POSS UNCON, & EVEN DEATH. EYE: IS AN EYE IRRIT. DIRECT CNTCT W/LIQ
EXPOS TO VAPS OR MIS TS MAY CAUSE STINGING, TEARING REDNESS &
SWELLING. SKIN: PRLNGD/RPTD CNTCT CAN CAUSE MOD IRRIT, DEFAT, (ING
4)
Medical Cond Aggravated by Exposure:RESPIRATORY SYMPTOMS ASSOCIATED
WITH PRE- EXISTING LUNG DISREDERS (E.G., ASTHMA-LIKE CONDITIONS)
MAY BE AGGRAVATED BY EXPOSURE TO INGREDIENT 1.
======================= First Aid Measures =======================
First Aid:INHAL:IF RESP SYMPS OR OTHER SYMPS OF EXPOSURE DEVELOP, MOVE
VICTIM AWAY FROM SOURCE OF EXPOSURE & INTO FRESH AIR. IF SYMPS
PERSIST, SEEK IMMED MED ATTN. IF VICITIM IS NOT BRTHG, IMMED BEGIN
ARTF RESP . IF BRTHG DFCLTS DEVELOP, OXYGEN SHLD BE ADMIN, SEEK MED
ATTN. EYE:MOVE VICTIM AWAY FROM EXPOS & INTO FRESH AIR. IF
IRRIT/REDNESS DEVELOPS, FLUSH EYES W/CLEAN WATER & SEEK MED ATTN.
(ING 7)
===================== Fire Fighting Measures =====================
Flash Point:104F,40C (ING 1)
Lower Limits:1%
Upper Limits:6%
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, HALON, POLAR OR
ALCOHOL FOAM, OR WATER SPRAY IS RECOMMENDED. WATER MAY BE
INEFFECITIVE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. MOVE UNDAMAGED CNTNRS FROM FIRE AREA IF IT CAN DONE WITHOUT RISK.
AVOID SPREADING BURNING LIQ (SUPP DATA)
Unusual Fire/Explosion Hazard:INGRED 1 IS FLAMM & MAY BE IGNIT BY HEAT/
SPARKS/FLAME/OTHER SOURCES OF IGNIT (E.G. STATIC ELECTRICITY, PILOT
LIGHTS, MECH/ELEC EQUIP). VAPS MAY (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:FLAMM. KEEP AWAY FROM ALL SOURCES OF IGNIT &
HOT SURFS. SPILLED MATL MAY BE ABSORBED INTO ANY ABSORB MATL. WEAR
APPROP PROT EQUIP INCL NIOSH/MSHA APPRVD RESP PROT AS CNDNTS
WARRANT. VENT AREA TILL ODO R IS GONE. AFTER ING 1 HAS BEEN
REMOVED(ING 11)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT EXPOSE ANY AEROSOL CAN TO
SUNLIGHT/ TEMP >120F TO PVNT POSS BURNING. ALL AEROSOL CAUTIONS
APPLY-USE IN WELL VENT AREAS. DO NOT BRTH SMOKE/FUMES
Other Precautions:WEAR APPROP PROT EQUIPMENT. USE AND STORE IN COOL,
DRY, WELL VENTILATED AREAS AWAY FROM HEAT, HOT SURFACES AND ALL
SOURCES OF IGNITION. PROT CNTNRS FROM PHYSICAL DMG. INDOOR STORAGE
SHLD MEET OSHA STD S & APPOP CODES. AS W/ANY CHEM -(ING 13)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NECESSARY UNLESS USED IN AN UNVENTILATED
AREA OR IN HIGH CONCENTRATIONS. NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:KEEP EXPOSURE BELOW LIMIT. KEEP WINDOWS OPEN. LOC EXHST:
WHEN USED REPEATLY IN QUANTITY. ELEC SYS SAFE FOR SUCH (ING 12)
Other Protective Equipment:NOT NECESSARY WITH ADEQUATE VENTILATION.
Work Hygienic Practices:AVOID BREATHING VAPORS AND CONTACT WITH SKIN OR
EYES, USE ADEQUATE VENTILATION. WASH HANDS AFTER USE.
Supplemental Safety and Health
FIRE FIGHT PROC: W/WATER USED FOR COOLING PURPOSES. EXPLO HAZ: TRAVEL
CONSIDERABLE DISTANCES TO A SOURCE OF IGNIT WHERE THEY MAY IGNITE,
FLASHBACK OR EXPLODE. VAP/AIR EXPLO HAZ INDOORS/ OUTDOORS OR IN
SEWERS. VAP ARE HVR/AIR & MAY ACCUM INLOW AREAS. IF CNTNR IS NOT
PROPERLY COOLED, IT MAY EXPLODE IN THE HEAT OF A FIRE
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:320F,160C
Vapor Pres:<12 @ 100F
Spec Gravity:0.750 @ 60F
Evaporation Rate & Reference:< 0.1 (BUTYL ACETATE=1)
Solubility in Water:NEGLGIBLE
Appearance and Odor:LIGHT PINK; SLIGHT ETHEREAL/HYDROCARBON ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID OPEN FLAMES AND HIGH TEMPERATURES.
AVOID ALL POSSIBLE SOURCES OF IGNITION.
Hazardous Decomposition Products:COMBUSTION MAY YIELD CARBON MONOXIDE
&/OR CARBON DIOXIDE VARIOUS HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY WITH FEDERAL, STATE AND LOCAL LAWS AND
REGULATIONS. EPA HAZ WASTE #'S F001 @ F002 MAY APPLY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:R-2505D, CHLORINE CHEMETS, ULR CHEMETS, VACUETTES, VACU-VIAL
CAGE:7K791
CAGE:7K791
============= Composition/Information on Ingredients =============
Ingred Name:FORMALDEHYDE SOLUTION, 37%
CAS:50-00-0
RTECS #:LP8925000
< Wt:.2
OSHA PEL:3 PPM, C
ACGIH TLV:2 PPM, C
ACGIH STEL:C0.37 MG/M3;C0.3 PPM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:PHOSPHORIC AICD, MONOPOTASSIUM SALT; (POTASSIUM PHOSPHATE
MONOBASIC)
CAS:7778-77-0
RTECS #:TC6615500
= Wt:2.
Ingred Name:METHANOL
CAS:67-56-1
RTECS #:PC1400000
= Wt:4.
OSHA PEL:260 MG/M3;200 PPM
ACGIH TLV:262 MG/M3;200 PPM
ACGIH STEL:328 MG/M3;250 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WATER; (DEIONIZED WATER)
CAS:7732-18-5
RTECS #:ZC0110000
> Wt:93.
Ingred Name:OTHER COMPONENTS
< Wt:1.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: IRRITATION. CHRONIC: IRRITATION
AND SENSITIZATION DERMATITIS.
Explanation of Carcinogenicity:FORMALDEHYDE: IARC MONOGRAPHS ON
EVALUATION OF CARCINOGENIC RISK OF CHEMICALS TO MAN, VOL 62, PG
217, 1995: GROUP 2A. NTP 8TH ANNUAL REPORT ON CARCINOGENS, 1994:
ANTICIPATD TO BE CARCINOGEN. ANIMAL: N ASAL TUMORS. OSHA REGULATED:
29 CFR 1910.1048.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:MAY CAUSE IRRITATION TO EYES, SKIN
AND MUCOUS MEMBRANES.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH WATER FOR AT LEAST 15 MINUTES.
SKIN:IMMEDIATELY FLUSH WITH WATER FOR 15 MINUTES. INGESTION: SEEK
MEDICAL ATTENTION. INHALATION: REMOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL OR CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NFPA RATINGS: HEALTH - 1; FLAMMABILITY -
0; REACTIVITY - 0.
================== Accidental Release Measures ==================
Spill Release Procedures:TAKE UP WITH ABSORBENT MATERIAL. PLACE IN
SMALL CONTAINERS FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:PRODUCT SHOULD BE STORED IN THE DARK
AND AT ROOM TEMPERATURE; HOWEVER, TEMPERATURES UP TO 120F OR EVEN
BELOW FREEZING WILL NOT NORMALLY AFFECT REAGENT PERFORMANCE. AVOID
CONTACT WITH EYES. FRAGILE: LI QUID IN GLASS. HANDLE WITH CARE.
AMPOULES. WARNING: DO NOT BREAK TIP OF AMPOULE UNLESS IT IS
COMPLETELY IMMERSED IN YOUR SAMPLE. BREAKING TIP IN AIR MAY CUSE
GLASS AMPOULE TO SHATTER . IF THIS PROD IS USED AS DIRECTED, THE
USER WILL NOT COME IN CONTACT WITH OR BE EXPOSED TO ANY OF I TS
CHEM COMPONENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Other Protective Equipment:EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO: VACU-VIALS. MFR INFO: FAX # (540) 788-4856 -
E-MAIL TECHINFO @ CHEMETRICS COM.
================== Physical/Chemical Properties ==================
Boiling Pt:=95.C, 203.F
Melt/Freeze Pt:=0.C, 32.F
Spec Gravity:1 (H*2O=1)
pH:4
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W ALL FEDERAL, STATE AND LOCAL
REGULATIONS.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PR-1436-G B-2, PART A
Kit Part:Y
Preparer's Name:JCS
CAGE:DO563
CAGE:83574
CAGE:DO563
============= Composition/Information on Ingredients =============
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION, DAMAGE. SKIN:
IRRITATION, ALLERGIC SKIN RASH. TOXIC BY SKIN ABSORPTION. LAB TEST
HAVE SHOWN THAT DERMAL APPLIC OF DMAC TO PREGNANT RATS PRODUCED
FETAL ABNORMALITIES. PROLONGED EXPOSU RE TO HEXAVALENT CHROMIUM
COMPOUNDS OVER THE PEL MAY CAUSE PAINLESS PENETRATING ULCERS OF THE
SKIN.
Effects of Overexposure:INHALATION (MIST OR DUST OF DRIED MATERIAL):
IRRITATION, NAUSEA, HEADACHE, WEAKNESS, POSSIBLE LIVER DAMAGE.
PENTRATING ULCERS OF MUCOUS MEMBRANES OF NOSE AND PERFORATION OF
CARTILAGINOUS NASAL SEPTUM. INGESTION: IRRITATION OF STOMACH AND
INTESTINES. NAUSEA, VOMITING, AND DIARRHEA. POSSIBLE LIVER AND
KIDNEY DAMAGE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LUKEWARM WATE FOR 15 MINUTES, CONSULT
PHYSICIAN. SKIN: WASH WITH SOAP AND WATER. IF SYMPTOMS PERSIST,
CONSULT PHYSICIAN. INHALATION: REMOVE TO FRESH AIR. IR SYMPTOMS ARE
PRESENT, CONS ULT PHYSICIAN. INGESTION: CONSULT A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Extinguishing Media:CO2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE AIR SUPPLIED RESPIRATOR. USE COMPLETE
PERSONAL PROTECTION. USE WATER TO COOL HEAT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE AND COVER THE SPILL WITH NON-OXIDIZABLE
ABSORBENT. SCOOP INTO CONTAINER. SPRINKLE SODIUM THIOSULFATE ON
RESIDUE. WORK INTO RESIDUE. SCOOP INTO DISPOSAL CONTAINER. CLEAN
AREA WITH WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:WASH THOROUGHLY AFTER HANDLING AND
BEFORE SMOKING OR EATING. AVOID INGESTION. TOXIC BY SKIN
ABSORPTION. AVOID ALL SKIN CONTACT.
Other Precautions:THIS PRODUCT CONTAINS A TOXIC CHEMICAL OR CHEMICALS
SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF TITLE III
OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 AND 40
CFR PART 372.
============= Exposure Controls/Personal Protection =============
Ventilation:GENERAL VENTILATION TO MAINTAIN VAPOR BELOW PEL.
SKIN (SPLASH) W/NITRILE/BUTYL/NATURAL RUBBER/POLYETHYLENE
APRON/COVERALLS.
Supplemental Safety and Health
ALTHOUGH THE CHROMIUM COMPOUNDS IN THIS PRODUCT ARE NOT DESIGNATED BY
NTP OR IARC AS CANCER CAUSING CHEMICALS, THE LIST ENTITLED
"CHEMICALS KNOWN TO THE STATE OF CALIFORNINA TO CAUSE CANCER" AS
REQUIR ED BY THE SAFE DRINKING WATER AND TOXICENFORMENT ACT
(PROPOSITION 65) INCLUDES ALL HEXAVALENT CHROMIUM COMOUNDS.
================== Physical/Chemical Properties ==================
HCC:F4
Spec Gravity:1.38
Solubility in Water:APPRECIABLE
Appearance and Odor:BLACK LIQUID
Percent Volatiles by Volume:76.5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
FLAMMABLE LIQUIDS.
Hazardous Decomposition Products:OXIDES OF CARBON AND NITROGEN,
CHROMIUM COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:EPA WASTE NUMBER D-007. DISPOSE OF SPILLAGE IN
COMPLIANCE WITH FEDERAL AND STATE REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:AC-236 ACCELERATOR
Kit Part:Y
Preparer's Name:RYAN MICKELSON
CAGE:1DWR5
CAGE:1DWR5
============= Composition/Information on Ingredients =============
Ingred Name:MANGANESE OXIDE
CAS:1313-13-9
RTECS #:OP0350000
= Wt:66.4
OSHA PEL:C5 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:TERPHENYL, HYDROGENATED
CAS:61788-32-7
RTECS #:WZ6535000
= Wt:22.7
ACGIH TLV:4.9 MG/M3;0.5 PPM
Ingred Name:1,3-DIPHENYLGUANIDINE
CAS:102-06-7
RTECS #:MF0875000
= Wt:.7
Ingred Name:TERPHENYL
CAS:26140-60-3
RTECS #:WZ6450000
= Wt:4.8
OSHA PEL:C9 MG/M3;C1 PPM
ACGIH STEL:C5 MG/M3;C0.53 PPM
Ingred Name:ETHOXYLATED NONYLPHENOL PHOSPHATE
CAS:51811-79-1
Code:F
= Wt:2.9
Ingred Name:SODIUM HYDROXIDE
CAS:1310-73-2
RTECS #:WB4900000
= Wt:1.4
OSHA PEL:2 MG/M3
ACGIH STEL:C2 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:NON-HAZARDOUS AND OTHER INGREDIENTS BELOW REPORTABLE
LEVELS.
= Wt:0.
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:EMERGENCY OVERVIEW: MAY CAUSE ALLERGIC
SKIN REACTION AND SENSITIZATION. INHALATION MAY CAUSE DIZZINESS.
HEADACHE AND INCOORDINATION. MAY CAUSE MODERATE EYE IRRITATION. MAY
CAUSE RESPIRATORY TRACT IRRI TATION. MAY CAUSE DIGESTIVE TRACT
IRRITATION. INGESTION MAY CAUSE NAUSEA, VOMITING, PAIN, UPSET
STOMACH, DIARRHEA. MAY CAUSE SKIN IRRITATION.
Effects of Overexposure:EYE CONTACT: MAY CAUSE MODERATE IRRITATION.
SKIN CONTACT: MAY CAUSE SLIGHT TO MILD IRRITATION. MAY CAUSE
ALLERGIC SKIN REACTIONS AND SENSITIZATION. INHALATION: IRRITATING
TO THE EYES, NOSE, AND RESPIR ATORY TRACT. CAN CAUSE DIZZINESS,
HEADACHES, AND INCOORDINATION. INGESTION: IRRITATING TO THE MOUTH,
THROAT, AND STOMACH. MAY CAUSE NAUSEA, VOMITING, PAIN, AND STOMACH
UPSET. `
Medical Cond Aggravated by Exposure:LIVER, KIDNEYS, LUNGS, AND
RESPIRATORY SYSTEM. SKIN. IMMUNE SYSTEMS AND/OR SPECIFIC CHEMICAL
ALLERGIES.
======================= First Aid Measures =======================
First Aid:EYE CONTACT: IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR
AT LEAST 15 MINUTES. GET MEDICAL ATTENTION IF IRRITATION PERSISTS.
SKIN CONTACT: IMMEDIATELY FLUSH WITH WATER. REMOVE CONTAMINATED
CLOTHING AND SHOES. GET MEDICAL ATTENTION IF IRRITATION PERSISTS.
PROFESSIONALLY WASH CLOTHING AND SHOES BEFORE RE-USE. INHALATION:
REMOVE TO FRESH AIR. IF SYMPTOMS DEVELOP, SEEK IMMEDIATE MEDICAL
ATTENTION.IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION.
INGESTION: SEEK MEDICAL ATTENTION. IMMEDIATELY INDUCE VOMITING,
DIRECT TREATMENT AT PREVENTING ABSORPTION, ADMINISTERING TO
SYMPTOMS, SUPPORTIVE THERAPY.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>93.3C, 200.F
Extinguishing Media:SMALL FIRES: DRY CHEMICAL, CARBON DIOXIDE, HALON,
WATER SPRAY, OR FOAM. LARGE FIRES: WATER SPRAY, FOG, OR ALCOHOL
FOAM.
Fire Fighting Procedures:FIRE FIGHTERS AND OTHERS WHO MAY BE EXPOSED TO
THE PRODUCTS OF COMBUSTION SHOULD BE EQUIPPED WITH NIOSH-APPROVED
POSITIVE PRESSURE SELF-CONTAINED BREATHING APPARATUS AD FULL
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:DURING A FIRE, IRRITATING AND HIGHLY
TOXIC GASES MAY BE GENERATED DURING COMBUSTION OR DECOMPOSITION.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATION: ISOLATE HAZARD AREA. KEEP
UNNECESSARY AND UNPROTECTED PERSONNEL FROM ENTERING. ELIMINATE ALL
SOURCES OF IGNITION. CONTAINMENT: SAFELY STOP DISCHARGE. CONTAIN
MATERIAL, AS NECESSARY, WITH A DIKE OR A BARRIER. STOP MATERIAL
FROM CONTAMINATING SOIL, OR FROM ENTERING SEWERS OR BODIES OF
WATER. CLEANUP/PERSONAL PROTECTION EQUIPMENT: APPROPRIATE SAFETY
MEASURES AND PROTECTIVE EQUIPMENT SHOUL
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE CONDITIONS: STORE IN A COOL,
DRY, WELL VENTILATED AREA AWAY FROM HEAT, IGNITION SOURCES, AND
DIRECT SUNLIGHT. KEEP CONTAINERS TIGHTLY CLOSED. TRANSFER: NO
SPECIAL PRECAUTIONS ARE NEEDED. FOLLO W GOOD MANUFACTURING AND
HANDLING PRACTICES. PERSONAL HYGIENE: WASH THOROUGHLY AFTER
HANDLING, ESPEC
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID BREATHING VAPOR AND/OR MISTS. WEAR
NIOSH/MSHA-APPROVED EQUIPMENT. DETERMINE THE APPROPRIATE TYPE BY
CONSULTING THE RESPIRATOR MANUFACTURER. HIGH AIRBORNE
CONCENTRATIONS MAY NECESSITATE THE USE OF SELF-CONTAINED
BREATHING APPARATUS OR A SUPPLIED AIR RESPIRATOR. RESPIRATORY
PROTECTION PROGRAMS MUST BE IN COMPLIANCE WITH 29 CFR 1910.134
Ventilation:LOCAL EXHAUST VENTILATION IS RECOMMENDED WHEN VAPORS,
MISTS, OR DUSTS CAN BE RELEASED IN EXCESS OF ESTABLISHED AIRBORNE
EXPOSURE LIMITS (TLV'S OR PEL'S).
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Pres:0.1MM HG
Vapor Density:>1
Spec Gravity:2.1
Evaporation Rate & Reference:<1
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK PASTE DISTINCT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS.
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:HAZARDOUS COMBUSTION AND
DECOMPOSITION: SMOKE, SOOT, TOXIC FUMES (CARBON DIOXIDE, CARBON
MONOXIDE), OXIDES OF NITROGEN, METALLIC OXIDES
=================== Toxicological Information===================
Toxicological Information:MANGANESE OXIDE: EYE, SKIN, AND RESPIRATORY
TRACT IRRITANT. CAN CAUSE LIVER AND KIDNEY INJURY.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL: DISPOSE IN ACCORDANCE WITH ALL LOCAL,
STATE, AND FEDERAL REGULATIONS. GENERAL STATEMENTS: FEDERAL
REGULATIONS MAY APPLY TO EMPTY CONTAINER. STATE AND/OR LOCAL
REGULATIONS MAY BE DIFFERENT. G ENERAL RECOMMENDATIONS: OF THE
METHODS OF DISPOSAL CURRENTLY AVAILABLE, IT IS RECOMMENDED THAT AN
AL TERNATIVE BE SELECTED ACCORDING TO THE FOLLOWING O
===================== Regulatory Information =====================
SARA Title III Information:SECTION 311/312-HAZARD CATEGORIES: N-FIRE
HAZARD N-SUDDEN RELEASE OF PRESSURE HAZARD, N-REACTIVITY HAZARD,
Y-IMMEDIATE HEALTH HAZARD, Y-DELAYED HEALTH HAZARD
Federal Regulatory Information:OZONE-DEPLETING CHEMICALS-NO REGULATED
INGREDIENTS. SARA SECTION 302 EXTREMELY HAZARDOUS MAT-NO REGULATED
INGREDIENTS. SARA SECTION 313 TOXIC CHEMICALS MANGANESE OXIDE.
CHEMICAL LISTING-LISTED ON THE FOLLOWING COUN
State Regulatory Information:PENNSYLVENIA-NEW JERSEY R-T-K MANGANESE
OXIDE 1313-13-9, TERPHENYL, HYDROGENATED 61788-32-7,
1,3-DIPHENYLQUANIDINE 102-06-7, TERPHENYL 26140-60-3, ETHOXYLATED
NONYLPHENOL PHOSPHATE51811-79-1, SODIUM H YDROXIDE 1310-73-2.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:NON-TOXIC GRINDER COOLANT
CAGE:FO332
CAGE:FO332
============= Composition/Information on Ingredients =============
Ingred Name:POLYETHYLENE GLYCOL
CAS:25322-68-3
RTECS #:TQ3500000
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE EXPECTED IN NORMAL USE
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NONE EXPECTED IN NORMAL USE
======================= First Aid Measures =======================
First Aid:EYES: IRRIGATION OF THE EYE IMMEDIATELY WITH WATER FOR 5
MINUTES IS A GOOD SAFETY PRACTICE. SKIN: WASH OFF WITH SOAP &
WATER. INGESTION: LOW IN TOXICITY INDUCE VOMITING IF LARGE AMOUNTS
ARE INGESTED. INHALATION: REMOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point:NON FLAMMABLE
Extinguishing Media:USE WATER SPRAY, CO2, DRY CHEMICAL, OR UNIVERSAL
TYPE FOAMS
Fire Fighting Procedures:USE SUPPLIED BREATHING AIR AND PROTECTIVE
CLOTHING.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP WITH ABSORBANT MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:EXERCISE REASONABLE CARE AND CAUTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED IN NORMAL USE
Ventilation:LOCAL EXHAUST: NORMAL ROOM VENTILATION
Other Protective Equipment:REGULAR WORK CLOTHES
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:207F
Spec Gravity:1.09
Solubility in Water:COMPLETE
Appearance and Odor:PALE YELLOW - MILD LEMON ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL
Hazardous Decomposition Products:BURNING CAN PRODUCE CO & CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:177 0890 FINAL RINSE & REPLENISHER,PROCESS E-6,CONCENTRATE
Preparer's Name:HEALTH &ENVIR. LABS
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 95-100%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYOXYETHYLENE 12 TRIDECYL ALCOHOL
CAS:24938-91-8
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SUBSTITUTED THIAZOLIN-3-ONE
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT REPORTED
Health Hazards Acute and Chronic:INHAL:MFG. REPORTS LOW HAZARD FOR
RECOMMENDED HANDLING.EYES:MAY CAUSE TRANSIENT IRRITATION.SKIN:MAY
CAUSE ALLERGIC REACTION.INGEST:MFG.STATES LOW INGESTION HAZARD.
Explanation of Carcinogenicity:NO DATA.
Effects of Overexposure:EYES:IRRITATION.SKIN:RASHES.
Medical Cond Aggravated by Exposure:NOT REPORTED.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR.IF SYMPTOMS PERSIST,CALL
PHYSICIAN.EYES:FLUSH WITH WATER FOR 15 MINUTES.CALL PHYSICIAN IF
SYMPTOMS PERSIST.SKIN:REMOVE CONTAMINATED CLOTHING.WASH WITH SOAP
AND WATER.INGEST:D RINK 1-2 GLASSES OF WATER.GET PROMPT QUALIFIED
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NON-COMBUSTIBLE
Extinguishing Media:USE APPROPRIATE AGENT FOR SURROUNDING FIRE.
Fire Fighting Procedures:NO SPECIAL REQUIREMENTS.HMIS SUGGESTS ALWAYS
USING A SELF-CONTAINED BRATHING APPARATUS WHENEVER FIGHTING A
CHEMICAL FIRE.
Unusual Fire/Explosion Hazard:MANUFACTURER STATES NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH VERMIVULITE OR OTHER SUITABLE
ABSORBANT.PLACE IN AN APPROPRIATE CONTAINER FOR DISPOSAL.WASH SPILL
AREA WITH WATER.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL REQUIREMENTS.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REPORTED.HMIS SUGGESTS USING A SCBA FOR
EMERGENCY SITUATIONS.
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT.
Other Protective Equipment:HMIS SUGGESTS EYE WASH AND SAFETY
SHOWER,PROTECTIVE CLOTHING TO AVOID CONTACT.
Work Hygienic Practices:WASH HANDS.SEPERATE WORK CLOTHES FROM STREET
CLOTHES.LAUNDER WORK CLOTHES BEFORE REUSE.KEEP FOOD OUT OF THE WORK
AREA.
Supplemental Safety and Health
CATLAOG #127 8035 CHANGED TO 177 0890 ON 1991.
================== Physical/Chemical Properties ==================
HCC:T6
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.01
pH:8.2
Evaporation Rate & Reference:0.4
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID;CLEAR;ODORLESS.SOLUTION MAY FOAM.
Percent Volatiles by Volume:99
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MANUFACTURER STATES NONE KNOWN.
Stability Condition to Avoid:NOT REPORTED.
Hazardous Decomposition Products:MANUFACTURER STATES NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
NIIN: 00-901-2088
Product ID: GLASS CLEANER,ANTIFOGGING,TYPE II,CLASS I
Cage: 1A862
=======================================================
Contractor Summary
=======================================================
Cage: 1A862
Box: 130435
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: GLASS CLEANER
Specification Number: A-A-40
Type/Grade/Class: TYPE 2,CLASS 1
Unit of Issue: GL
UI Container Qty: 4
Type of Container: PLASTIC BOTTL
=======================================================
Ingredients
=======================================================
Cas: 111-76-2
RTECS #: KJ8575000
% Wt: 5.5
Other REC Limits: NONE RECOMMENDED
OSHA PEL: S, 50 PPM
ACGIH TLV: S, 25 PPM; 9596
------------------------------
Cas: 67-63-0
RTECS #: NT8050000
% Wt: 4.5
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 400 PPM
ACGIH TLV: 400 PPM/500STEL;9596
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50 (ORAL, RAT) IS NOT KNOWN.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: TARGET ORGANS:EYE, SKIN, RESPIRATORY & GI TRACTS.
ACUTE & CHRONIC - EYE CONTACT MAY CAUSE IRRITATION & CORNEAL INJURY.
PROLONGED SKIN ABSORPTION, INHALATION OR SWALLOWING MAY CAUSE HEADACHE,
DIZZINESS , NAUSEA & VOMITING. MAY CAUSE MUCOUS MEMBRANE IRRITATION.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: IRRITATION, TEARING, NAUSEA, VOMITING,
HEADACHES, DIARRHEA, DIZZINESS
Medical Cond Aggravated By Exposure: PERSONS WITH PRE-EXISTING SKIN DISORDERS,
EYE PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION MAY BE MORE SUSCEPTIBLE TO THE
EFFECTS OF THIS PRODUCT.
First Aid: CALL PHYSICIAN IF SYMPTOMS PERSIST. EYE:IMMEDIATELY FLUSH WITH WATER
FOR 15 MINUTES. HOLD EYELIDS OPEN. CALL PHYSICIAN. SKIN:WASH WITH SOAP &
WATER. INHALED:REMOVE TO FRESH AIR. PROVIDE CPR/OXYGEN IF NEEDED. ORAL:IF
CONSCIOUS, DRINK WATER & INDUCE VOMITING. CALL A PHYSICIAN/POISON CONTROL
CENTER IMMEDIATELY. NEVER GIVE FLUID OR INDUCE VOMITING IF PATIENT IS
UNCONSCIOUS OR HAS CONVULSIONS.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: PREVENT SKIN AND EYE CONTACT. ABSORB SPILLS WITH
INERT MATERIAL SUCH AS SAND OR VERMICULITE OR USE PUMP. PLACE IN PROPER
CONTAINERS FOR DISPOSAL. DO NOT FLUSH TO SEWER OR WATERWAYS. WASH SPILL AREA
WI TH WATER.
Neutralizing Agent: NOT RELEVANT
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE AND
FEDERAL REGULATIONS. INCINERATION IS RECOMMENDED.
Handling And Storage Precautions: STORE IN COOL, DRY PLACE, AWAY FROM SPARKS,
FLAMES, OXIDIZING AGENTS. AVOID FREEZING.
Other Precautions: WASH THOROUGHLY WITH SOAP AND WATER AFTER HANDLING AND
BEFORE EATING, DRINKING, SMOKING. KEEP OUT OF REACH OF CHILDREN. DO NOT TAKE
INTERNALLY. DO NOT INHALE. DO NOT GET IN EYES OR ON SKIN. DO NOT CON TMINATE
FOOD AND FEED.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: 120F,49C
Lower Limits: UNKNOWN
Upper Limits: UNKNOWN
Extinguishing Media: WATER FOG, CARBON DIOXIDE, FOAM OR DRY CHEMICAL. USE WATER
SPRAY TO COOL FIRE EXPOSED CONTAINERS.
Fire Fighting Procedures: WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. EVACUATE PERSONNEL TO A SAFE AREA.
Unusual Fire/Explosion Hazard: VAPOR IS HEAVIER THAN AIR AND CAN TRAVEL
CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK. CONTAINERS MAY
RUPTURE DUE TO VAPOR PRESSURE BUILDUP.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE REQUIRED WHERE ADEQUATE VENTILATION CONDITIONS
EXIST. IF AIRBORNE CONCENTRATION IS HIGH, WEAR A NIOSH-APPROVED ORGANIC VAPOR
RESPIRATOR.
Ventilation: ADEQUATE
Other Protective Equipment: EYE WASH STATION, SAFETY SHOWER, PROTECTIVE
CLOTHING
Work Hygienic Practices: OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: F4
NRC/State LIC No: NOT RELEVANT
B.P. Text: 180F,82C
M.P/F.P Text: 25.0F,-3.9C
Decomp Text: UNKNOWN
Vapor Pres: <1
Vapor Density: >1
Spec Gravity: <1
PH: 9 - 11
Viscosity: UNKNOWN
Evaporation Rate & Reference: UNKNOWN
Solubility in Water: COMPLETE
Appearance and Odor: CLEAR, BLUE COLOR LIQUID - MILD ALCOHOL ODOR
Corrosion Rate: UNKNOWN
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: EXCESSIVE HEAT, SPARKS, FLAME, FREEZING
Materials To Avoid: OXIDIZING AGENTS
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE AND OTHER
HYDROCARBONS
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 90985
Product ID: GLASS CLEANER,ANTIFOGGING,TYPE II,CLASS I
Review Date: 06/11/1996
Tech Entry NOS Shipping Nm: CONTAINS ISOPROPANOL (4.5%).
Radioactivity: NOT RELEVANT
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: GL
Container QTY: 4
Type Of Container: PLASTIC BOTTL
Additional Data: PROPER SHIPPING NAME, UN ID NUMBER, PER MSDS.
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: GJL
Symbols: G
DOT Proper Shipping Name: FLAMMABLE LIQUIDS, N.O.S.
Hazard Class: 3
UN ID Num: UN1993
DOT Packaging Group: III
Label: FLAMMABLE LIQUID
Special Provision: B1,B52,T7,T30
Packaging Exception: 150
Non Bulk Pack: 203
Bulk Pack: 242
Max Qty Pass: 60 L
Max Qty Cargo: 220 L
Vessel Stow Req: A
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: HIA
IMO Proper Shipping Name: FLAMMABLE LIQUID, N.O.S. o
IMDG Page Number: 3345
UN Number: 1993
UN Hazard Class: 3.3
IMO Packaging Group: III
Subsidiary Risk Label: -
EMS Number: 3-07
MED First Aid Guide NUM: T
=======================================================
Detail IATA Information
=======================================================
IATA PSN CA
IATA UN ID Num: 1993
IATA Proper Shipping Name: FLAMMABLE LIQUID, N.O.S. *
IATA UN Class: 3
IATA Label: FLAMMABLE LIQUID
UN Packing Group: III
Packing Note Passenger: 309
Max Quant Pass: 60L
Max Quant Cargo: 220L
Packaging Note Cargo: 310
=======================================================
Detail AFI Information
=======================================================
AFI PSN CA
AFI Symbols: *
AFI Proper Shipping Name: FLAMMABLE LIQUIDS, N.O.S.
AFI Hazard Class: 3
AFI UN ID NUM: UN1993
AFI Packing Group: III
Special Provisions: P5
Back Pack Reference: A7.3
=======================================================
HAZCOM Label
=======================================================
Product ID: GLASS CLEANER,ANTIFOGGING,TYPE II,CLASS I
Cage: 1A862
Company Name: LIGHTHOUSE FOR THE BLIND OF HOUSTON
Street: 3530 W DALLAS
PO Box: 130435
Zipcode: 77021-0435
Label Required IND: Y
Date Of Label Review: 06/11/1996
Status Code: C
MFG Label NO: UNKNOWN
Label Date: 06/11/1996
Origination Code: F
Skin Protection IND: YES
Signal Word: WARNING
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: TARGET ORGANS:EYE, SKIN, RESPIRATORY & GI TRACTS.
ACUTE & CHRONIC - EYE CONTACT MAY CAUSE IRRITATION & CORNEAL INJURY.
PROLONGED SKIN ABSORPTION, INHALATION/SWALLOWING MAY CAUSE CNS EFFECTS. STORE
AWA Y FROM INCOMPATIBLES. ABSORB SPILLS WITH INERT MATERIAL SUCH AS SAND/USE
PUMP. PLACE IN PROPER CONTAINERS FOR DISPOSAL. FIRST AID- CALL PHYSICIAN IF
SYMPTOMS PERSIST. EYE:IMMEDIATELY FLUSH WITH WATER FOR 15 MINUTES. HOLD
EYELIDS OPEN. CALL PHYSICIAN. SKIN:WASH WITH SOAP & WATER.INHALED:REMOVE
TO FRESH AIR. PROVIDE CPR/OXYGEN IF NEEDED. ORAL:IF CONSCIOUS, DRINK WATER
& INDUCE VOMITING. CALL A PHYSI CIAN/POISON CONTROL CENTER IMMEDIATELY.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FA1745
CAGE:JO774
CAGE:81831
CAGE:JO774
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMED.SKIN:WASH W/SOAP IMMED.INHAL:REMOVE
TO FRESH AIR.GIVE ART.RESPIR. AS NEEDED.INGEST:GET MEDICAL
ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE VOMITING,BUT DO NOT MAKE
UNCONSCIOUS PE RSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS.CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE,THROAT.
================== Physical/Chemical Properties ==================
HCC:V1
Appearance and Odor:LIGHT STRAW COLORED LIQUID,AROMATIC ODOR.
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:JP 4
CAGE:5W181
CAGE:5W181
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM HYDROCARBONS MIDDLE DISTILLATE TO INCLUDE
68410-71-9 AND 64742-49-0.
CAS:64742-81-0
Fraction by Wt: 100% %
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MODERATE EYE IRRITATION, ASPIRATION
HAZARD WHICH MAY LEAD TO PNEUMONITIS, CENTRAL NERVOUS SYSTEM
DEPRESSION, SKIN IRRITATION.
Explanation of Carcinogenicity:PRODUCT CONTAINS NO INGREDIENTS
CURRENTLY CLASSIFIED AS CARCINOGENIC BY NTP, IARC OR OSHA.
Effects of Overexposure:EYE IRRITATION, SKIN IRRITATION WITH BURNS AND
BLISTERING POSSIBLE, VOMITING, NAUSEA, DROWSINESS, NARCOSIS.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH WATER FOR SEVERAL MINUTES,
HOLDING EYELIDS OPEN. INGESTION: DO NOT INDUCE VOMITING. CALL A
DOCTOR IMMEDIATELY. INHALATION: REMOVE TO FRESH AIR. IF BREATHING
HAS STOPPED, A PPLY ARTIFICIAL RESPIRATION. CALL A DOCTOR. SKIN:
WASH SKIN THOROUGHLY WITH SOAP AND WATER.
===================== Fire Fighting Measures =====================
Flash Point:<100F,<38C
Lower Limits:1.3 %
Upper Limits:8.0 %
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, FOAM, CARBON DIOXIDE
Fire Fighting Procedures:WATER OR FOAM MAY CAUSE FROTHING. USE WATER TO
COOL FIRE-EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:FULL BODY FLAME-RESISTANT CLOTHING AND/OR
TURN-OUT GEAR RECOMMENDED FOR PERSONS ATTEMPTING LEAK OR SPILL
CONTROL AND FOR FIRE FIGHTING.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES INCLUDING INTERNAL
COMBUSTION ENGINES, DE-ENERGIZE ELECTRICAL EQUIPMENT AND SYSTEMS.
VENTILATE AREA. FOR LIQUIDS, CONTAIN SPILL IF POSSIBLE. REMOVE WITH
INERT ABSORBENT. USE PROPER PERSONAL PROTECTIVE EQUIPMENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS AND FLAME.
EMPTY CONTAINERS RETAIN RESIDUE AND CAN BE DANGEROUS.
Other Precautions:DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL,
GRIND OR EXPOSE EMPTY CONTAINERS TO HEAT, FLAME, SPARKS, STATIC
ELECTRICITY OR OTHER SOURCES OF IGNITION: THEY MAY EXPLODE AND
CAUSE INJURY OR DEATH .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXOSURES BELOW PEL (TLV), USE NIOSH/MSHA APPROVED RESPIRATOR AS PER
CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS AND NIOSH RESPIRATOR
SELECTION.
Ventilation:UNDER NORMAL APPLICATIONS OF THIS PRODUCT, GENERAL
VENTILATION IS ADEQUATE.
Other Protective Equipment:WEAR IMPERVIOUS PROTECTIVE CLOTHING MADE
FROM NEOPRENE, NITRILE OR N-BUTYL RUBBER.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
EMPTY DRUMS SHOULD BE COMPLETELY DRAINED, PROPERLY BUNGED AND PROMPTLY
RETURNED TO A DRUM RECONDITIONER. NOTE: MIDDLE DISTILLATE HAS
CAUSED SKIN CANCER IN LABORATORY ANIMALS BRIEF OR INTERMITTENT SKIN
CONTACT IS NOT EXPECTED TO CAUSE ANY ADVERSE EFFECTS IF IT IS
WASHED FROM THE SKIN.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:=245.C, 473.F
Vapor Pres:72
Vapor Density:NOT GIVEN
Spec Gravity:0.76
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:NIL
Appearance and Odor:CLEAR, COLORLESS LIQUID
Percent Volatiles by Volume:100 %
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS AND FLAMES
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FERROUS PERCHLORATE HYDRATED, 42
CAGE:GFS00
CAGE:77964
CAGE:GFS00
============= Composition/Information on Ingredients =============
Ingred Name:FERROUS PERCHLORATE, HYDRATED
CAS:13933-23-8
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CORROSIVE TO SKIN AND EYES.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN: WASH WITH WATER. EYE: WASH WITH WATER FOR AT LEAST 15
MINUTES. IF IRRITATION PERSISTS, GET MEDICAL ATTENTION. INGEST:
GIVE WATER WITH MILK OF MAGNESIA AND INDUCE VOMITING. INHAL: REMOVE
TO FRESH AIR. SUPPORT BRTHG (GIVE O2/ARTF RESP).
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MAY CAUSE FIRE WITH WOOD, PAPER OR CLOTH.
================== Accidental Release Measures ==================
Spill Release Procedures:WASH UP QUICKLY AND THOROUGHLY WITH WATER.
DISPOSAL TO DRAIN. RINSE ANY MOPS USED THOROUGHLY WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM MATERIALS BEARING RED
(FLAMMABLE) LABELS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:ANSI APPRVD EMERGENCY EYEWASH AND DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EYE PROT: W/FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:SOLUBLE
Appearance and Odor:LIGHT GREEN CRYSTALS. ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
POTENTIAL OXIDIZER. DO NOT HEAT WITH ORGANIC MATERIALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE AND LOCAL
REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ZINC CHLORIDE,GRANULAR
CAGE:SPPRD
CAGE:7X274
CAGE:SPPRD
============= Composition/Information on Ingredients =============
Ingred Name:ZINC CHLORIDE (SARA III)
CAS:7646-85-7
RTECS #:ZH1400000
Fraction by Wt: >94%
OSHA PEL:1 MG/M3/2 STEL
ACGIH TLV:1 MG/M3/2STEL FUME93
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:CAUSES BURNS TO SKIN,EYES,MEMBRANES,ETC.
======================= First Aid Measures =======================
First Aid:EYES-FLUSH W/WATER 15 MIN. TAKE OFF CONTAM CLOTHING
===================== Fire Fighting Measures =====================
Flash Point:NONE
Unusual Fire/Explosion Hazard:MAY RELEASE TOXIC FUMES IF INVOLVED IN A
FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:COLLECT IN A PLASTIC CONTAINERS. NEUTRALIZE
FLOOR W/LIME. AVOID CONTACT W/SKIN & EYES.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. AVOID
CONTACT W/MOISTURE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CARTRIDG OR FILTER RESPIRATOR ADVISABLE FOR
FUMES.
Ventilation:ADEQUATE TO KEEP VAP CONC BELOW TLV. SCRUB AIR BEOFRE
RECIRC
Other Protective Equipment:DEPENDS ON SPECIFIC USAGE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:1350F/732C
Spec Gravity:2.905
Solubility in Water:APPRECIABLE
Appearance and Odor:WHITE,ODORLESS CRYSTALS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH W/WATER IN CHEMICAL SEWER.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:0536 AVOCADO
CAGE:ZYNOL
CAGE:ZYNOL
CAGE:25461
============= Composition/Information on Ingredients =============
Ingred Name:BUTYL ACETATE (N-BUTYL ACETATE)
CAS:123-86-4
RTECS #:AF7350000
Other REC Limits:150 PPM
OSHA PEL:700 MG/CUM
ACGIH TLV:713 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:HYDROCARBON RESIN, ARIEN, PETROLEUM RESIN
CAS:64742-16-1
RTECS #:CF2550000
Other REC Limits:NONE
OSHA PEL:NONE
ACGIH TLV:NONE
Ingred Name:RED IRON OXIDE/IRON (III) OXIDE/FERRIC OXIDE/YELLOW FERRIC
OXIDE/METAL OXIDE/YELLOW IRON OXIDE/IRON OXIDE PIGMENT/IRON
CAS:1309-37-1
RTECS #:NO7400000
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:MEDIUM ALIPHATIC NAPHTHA (AROMATIC 100), PARAFFIN-NAPTHANES
MINERAL SPIRITS *92/3*
CAS:64742-88-7
Other REC Limits:100 PPM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:BUTANOL, N-BUTYL ALCOHOL, PROPYL CARBINOL, BUTYL ALCOHOL
CAS:71-36-3
RTECS #:EO1400000
Other REC Limits:300 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:NON HAZARDOUS POLYMER (TYPE NOT SPECIFIED)
Ingred Name:SILICA DIOXIDE, CRYSTALLINE QUARTZ, SAND (SUSPECTED HUMAN
CARCINOGEN BY IARC)
CAS:14808-60-7
RTECS #:VV7330000
Other REC Limits:0.05 MG/CUM NIOSH
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:SILICONE RESIN
Ingred Name:TITANIUM DIOXIDE, TIO2
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Other REC Limits:375 MG/CUM
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:LIGHT ALIPHATIC NAPHTHA, VM&P NAPHTHA *92/3*
CAS:64742-89-8
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
CAS:1330-20-7
RTECS #:ZE2100000
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROETHANE) (CHLOROTHENE NU),
AEROTHANE TT, CHLOROTHENE
CAS:71-55-6
RTECS #:KJ2975000
Other REC Limits:450 PPM STEL
OSHA PEL:350 PPM
ACGIH TLV:1910 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC, HIGH FLASH
AROMATIC NAPHTHA
CAS:64742-95-6
RTECS #:WF3400000
OSHA PEL:25 PPM
ACGIH TLV:25 PPM
Ingred Name:WEIGHT PER GALLON IN POUNDS: 6.2 TYPICAL
RTECS #:9999999WG
Ingred Name:ACETONE; DIMETHYL KETONE
CAS:67-64-1
RTECS #:AL3150000
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INGESTION: GASTRO-INTESTINAL DISTRESS.
INHALATION: NOSE & THROAT IRRITATION, EYE WATERING, HEADACHES,
NAUSEA, DIZZINESS, & LOSS OF COORDINATION. EYE: IRRITATION &
BURNING. SKIN: ABSORPTION IN HARMFUL AMOUNTS.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:INHALATION: CENTRAL NERVOUS SYSTEM EFFECTS,
PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE. KIDNEY & LIVER DAMAGE.
SKIN: IRRITATION W/DISCOMFORT & DERMATITIS. EYES: CORROSION &
PERMANENT INJURY.
======================= First Aid Measures =======================
First Aid:INGESTION: DON'T INDUCE VOMITING. INHALATION: REMOVE TO FRESH
AIR. GIVE ARTIFICIAL RESPIRATION, PREFERABLY MOUTH-TO-MOUTH. EYES:
FLUSH IMMEDIATELY W/PLENTY OF WATER FOR AT LEAST 15 MINS. SKIN:
WASH W/ SOAP & WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:<20F
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT, INCLUDING
SCBA. WATER MAY BE INEFFECTIVE. FOG NOZZLES MAY BE USED TO COOL
CLOSED CONTAINERS TO PREVENT PRESSURE BUILD-UP.
Unusual Fire/Explosion Hazard:CONTENTS UNDER PRESSURE. CONTAINER MAY
BURST, PROPELLING CONTENTS ACROSS AREA WHEN EXPOSED TO HEAT.
FLAMMABLE GAS.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE SOURCES OF IGNITION.
CONFINE & REMOVE W/INERT ABSORBENT. FOR EASE OF CLEANUP, USE
PROTECTIVE CREAMS.
======================Handling and Storage ======================
Handling and Storage Precautions:OBSERVE LABEL PRECAUTIONS. KEEP AWAY
FROM HEAT, SPARKS, FLAME. DON'T STORE >120F. DON'T EXPOSE TO DIRECT
SUNLIGHT TO AVOID BURSTING.
Other Precautions:DON'T SAND, FLAME CUT, BRAZE, OR WELD DRY COATING
W/OUT PROPER PROTECTION. DON'T PUNCTURE. DON'T SPRAY NEAR FIRE OR
OPEN FLAME. AVOID CONTACT W/SKIN. AVOID INHALATION OF VAPORS OR
MISTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR AN APPROPRIATE, PROPERLY FITTED RESPIRATOR
(NIOSH/MSHA APPROVED) DURING & AFTER APPLICATION UNLESS AIR
MONITORING DEMONSTRATES VAPOR/MIST LEVELS ARE BELOW APPLICABLE
LIMITS. FOLLOW MANUFACTURER'S DIRECTIONS FOR USE.
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME & PATTERN TO KEEP
CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Other Protective Equipment:COVERALLS, PROTECTIVE CREAMS MAY BE USED FOR
EASE OF CLEAN-UP, NOT FOR PROTECTION. SIDE SHIELDS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE EATING
& SMOKING.
Supplemental Safety and Health
PERCENT VOLATILE BY WEIGHT: 85%. 1,1,1, TRICHLOROETHANE CAN CHEMICALLY
REACT WITH ALUMINUM IN EQUIPMENT & CAUSE AN EXPLOSION HAZARD.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:<0F
Vapor Density:>1
Evaporation Rate & Reference:FASTER THAN ETHER
Solubility in Water:MODERATE-APPRECIABLE
Appearance and Odor:AVOCADO
Percent Volatiles by Volume:92%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALUMINUM
Stability Condition to Avoid:TEMPERATURES >120F, DIRECT SUNLIGHT, FIRE,
OPEN FLAMES, SPARKS, & OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:CO, CO2, SMOKE, OXIDES OF HEAVY METALS
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T ALLOW MATERIAL TO CONTAMINATE GROUND WATER
SYSTEMS. INCINERATE ABSORBED MATERIAL IN ACCORDANCE W/STATE,
FEDERAL, & LOCAL REGULATIONS. DON'T INCINERATE IN CLOSED
CONTAINERS. FLAMMABLE GAS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:06 0589WIT MILP24441/3 F152 TY1
Kit Part:Y
CAGE:91346
CAGE:91346
============= Composition/Information on Ingredients =============
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SILICON DIOXIDE (AMORPHOUS)
CAS:67762-90-7
Fraction by Wt: 1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TALC
CAS:14807-96-6
RTECS #:MW2700000
Fraction by Wt: 25%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:0.2 FIBERS/CC; 9394
Ingred Name:EPOXY RESIN
CAS:25068-38-6
RTECS #:KC2100000
Fraction by Wt: 50%
Other REC Limits:NONE RECOMMENDED
Ingred Name:CUMENE (SARA III)
CAS:98-82-8
RTECS #:GR8575000
Fraction by Wt: 1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 50 PPM; 9394
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:NAPHTHA, LIGHT AROMATIC
CAS:64742-95-6
Fraction by Wt: 15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM 9091
Ingred Name:1,2,4-TRIMETHYLBENZENE (SARA III)
CAS:95-63-6
RTECS #:DC3325000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:25 PPM
ACGIH TLV:25 PPM; 9394
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: HARMFUL IF INHALED. MAY EFFECT
THE BRAIN, NERVOUS SYSTEM OR RESPIRATORY SYSTEM. OVEREXPOSURE TO
INGREDIENTS IN THIS PRODUCT MAY CAUSE NOSE & THROAT IRRITATION, EYE
IRRITATION, SKIN IRRITATION, LIVER DAMAGE, KIDNEY DAMAGE. CHRONIC:
REPORTS HAVE ASSOCIATED OVEREXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN DAMAGE.
Explanation of Carcinogenicity:NOT CARCINOGENIC.
Effects of Overexposure:MAY CAUSE DIZZINESS, HEADACHE, NAUSEA OR
RESPIRATORY IRRITATION. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING AND INHALING THE CONTENTS MAY BE HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:ANY RESPIRATORY OR SKIN CONDITION.
======================= First Aid Measures =======================
First Aid:EYE-FLUSH IMMEDIATELY WITH PLENTY OF WATER FOR AT LEAST 15
MIN & GET MEDICAL ATTENTION. SKIN-WASH THOROUGHLY WITH SOAP &
WATER. INHALATION-IF AFFECTED BY INHALATION OF VAPOR OR SPRAY MIST,
REMOVE TO F RESH AIR. SWALLOWING-IF SWALLOWED, GET MEDICAL
ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:115F,46C
Lower Limits:1.00
Upper Limits:7.00
Extinguishing Media:CARBON DIOXIDE, DRYC EHMICAL, FOAM, AND/OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS MUST WEAR SELF-CONTAINED
BREATHING APPARATUS OR AIR MASKS. CONTAINERS EXPOSED TO FIRE SHOULD
BE KEPT COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. AVOID BREATHING OF VAPORS. USE
SELF-CONTAINED BREATHING APPARATUS OR AIR MASK FOR LARGE SPILLS IN
A CONFINED AREA. AVOID ALL PERSONAL CONTACT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS AND OPEN
FLAMES. KEEP CONTAINER CLOSED WHEN NOT IN USE. DO NOT STORE ABOVE
120F.
Other Precautions:EMPTY CONTAINERS MAY CONTAIN PRODUCT RESIDUE.
INCLUDING FLAMMABLE OR EXPLOSIVE VAPORS. DO NOT CUT, PUNCTURE OR
WELD ON OR NEAR CONTAINER. ALL LABEL WARNINGS MUST BE OBSERVED
UNTIL THE CONTAINER HAS BE EN CLEANED OR RECONDITIONED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPIATE, PROPERLY FITTED RESPIRATOR
(NIOSH/MSHA APPROVED) DURING & AFTER APPLICATION UNLESS AIR
MONITORING VAPOR/MIST LEVELS ARE BELOW APPLICABLE LIMITS. FOLLOW
RESPIRATOR MANUFACTURERS DIRECT ION FOR RESPIRATOR USE.
Ventilation:REQUIRED FOR SPRAYING OR IN A CONFINED AREA, VENTILATION
EQUIPMENT SHOULD BE EXPLOSION PROOF.
Other Protective Equipment:NEOPRENE OR PLASTIC APRON AND PROTECTIVE
CLOTHING COVERING EXPOSED SKIN AREAS.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING AND BEFORE
USING RESTROOMS.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:282F,139C
Vapor Pres:6.0
Vapor Density:4.3
Spec Gravity:1.24
Evaporation Rate & Reference:0.6 (N-BUTYL ACETATE=1)
Solubility in Water:NO
Appearance and Odor:NORMAL FOR A COATING PRODUCT.
Percent Volatiles by Volume:35.8
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:SILICON DIOXIDE, CARBON
DIOXIDE/MONOXIDE, METAL OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN CHEMICAL DISPOSAL AREA OR IN A MANNER
THAT COMPLIES WITH LOCAL, STATE AND FEDERAL REGULATIONS. DO NOT
INCINERATE CLOSED CONTAINERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DAN P/S GL W/ULTRA-VIOLET IN ACRYLIC ENAMEL
Preparer's Name:J.B.R.
CAGE:0GB20
CAGE:0GB20
============= Composition/Information on Ingredients =============
Ingred Name:AROMATIC PETROLEUM DISTILLATES; (HYDROCARBON MIXTURE).
VP:2@20C
CAS:64741-41-9
Fraction by Wt: 65%
ACGIH TLV:100PPM;200 STEL(MFR)
Ingred Name:1H-BENZOTRIAZOLE; (BENZOTRIAZOLE)
CAS:95-14-7
RTECS #:DM1225000
Fraction by Wt: 5%
Ingred Name:BENZIN; (PETROLEUM HYDROCARBON FRACTION). VP: 2@20C
CAS:8030-30-6
RTECS #:DC3030000
Fraction by Wt: 5%
ACGIH TLV:275 PPM (MFR)
Ingred Name:VOLATILE ORGANIC COMPOUNDS: 4.51 LB/GAL, 541 GR/LTR
RTECS #:9999999VO
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: OVEREXP CAN LEAD TO CNS DEPRESS
PRDCG SUCH EFTS AS HDCH, DIZZ, NAUS, & LOSS OF CONSCIOUSNESS. EYE:
SHORT-TERM CONT MAY RSLT IN SLIGHT IRRIT. PRLNGD & RPTD CONT MAY BE
MORE IRRITATING. SKIN: PRL NGD & RPTD LIQ CONT CAN CAUSE DEFAT &
DRY OF SKIN WHICH MAY RSLT IN IRRIT & DERM. TESTS SHOW OVEREXP
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: MAY CAUSE BLOOD DISORDERS &
NEUROLOGIC DISORDERS. RPTS HAVE ASSOC RPTD & PRLNGD OCCUP OVEREXP
TO SOLV W/PERM BRAIN & NERV SYS DAM. INTENTIONAL MISUSE OF PROD MAY
BE HARMFUL/FATAL.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WATER FOR @ LST 15 MIN WHILE HOLDING LIDS OPEN.
GET MED ATTN. SKIN:WASH W/SOAP & WATER. REMOVE CONTAMD CLTHG &
SHOES; DO NOT REUSE UNTIL CLEANED. IF PERSISTENT IRRIT OCCURS, GET
MED ATTN. INHAL:REMOVE TO FRESH AIR & PROVIDE OXYGEN IF BRTHG
DFCLT. GIVE ARTF RESP IF NOT BRTHG. GET MED ATTN. INGEST: SEEK EMER
MED ATTN. DO NOT GIVE ANYTHING BY MOUTH TO AN UNCON PERSON. DO NOT
INDUCE VOMIT.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:108F,42C
Lower Limits:1%
Upper Limits:6.1%
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
EVACUATE HAZ AREA OF UNPROTECTED PERS. COOL FIRE-EXPOS CONTRS
W/WATER. AVOID SPREADING BURNING LIQ (SUPP DATA)
Unusual Fire/Explosion Hazard:THIS MATERIAL IS FLAMMABLE AND MAY BE
IGNITED BY HEAT, SPARKS, FLAME OR STATIC ELECTRICITY.
================== Accidental Release Measures ==================
Spill Release Procedures:STAY UPWIND AND AWAY FROM SPILL. KEEP ALL
SOURCES OF IGNITION AND HOT METAL SURFACES AWAY FROM SPILL. IF
SPILL IS INDOORS, VENTILATE AREA OF SPILL. IF LARGE SPILL, CALL
SPILL RESPONSE TEAM. NOTIFY APP ROPRIATE STATE/LOCAL AGENCIES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & OPEN
FLAME. KEEP CONTRS TIGHTLY CLSD. STORE AWAY FROM OXIDIZING AGENTS
IN A COOL, DRY PLACE W/ADEQ EXPLOS-PROOF VENT.
Other Precautions:GROUND EQUIPMENT TO PREVENT ACCUMULATION OF STATIC
CHARGE. IF POURING OR TRANSFERRING MATERIALS, CONTAINERS MUST BE
BONDED & GROUNDED. DO NOT WELD, HEAT/DRILL ON OR NEAR CONTAINER;
EVEN EMPTIED CONTAI NERS CAN CONTAIN EXPLOSIVE VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DPNDG ON NATURE & CONC OF AIRBORNE MATL, USE A
NIOSH/MSHA APPRVD RESP/GAS MASK W/APPROP CARTRIDGES & CANNISTERS
(IF AVAILABLE) OR SUPPLIED AIR EQUIPMENT.
Ventilation:USE EXPLOS-PROOF VENT AS REQD TO CTL VAP CONC. TO MAINTAIN
AIRBORNE CONC BELOW ESTABLISHED EXPOS LIM, ADDNL (SUPP DATA)
Other Protective Equipment:WEAR PROTECTIVE CLOTHING AS REQUIRED TO
PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH WITH SOAP & WATER BEFORE EATING, DRINKING,
SMOKING OR USING TOILET FACILITIES. LAUNDER CONTAMD CLTHG BEFORE
REUSE.
Supplemental Safety and Health
FIRE FIGHT PROC: W/WATER USED FOR COOLING PURPOSES. VENT: VENT OR
EXHAUST SYSTEMS MAY BE REQUIRED.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:>204F,>96C
Vapor Pres:SEE INGRED
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:67.9
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID HEAT, SPARKS, & OPEN FLAME. AVOID
CONTACT WITH ALKALIES, AQUEOUS ACIDS, AMINES, AND ACIDIC ALCOHOLS.
Hazardous Decomposition Products:THERMAL DECOMPOSITION IN THE PRESENCE
OF AIR MAY YIELD CARBON MONOXIDE &/OR CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF PRODUCT IN ACCORDANCE WITH LOCAL,
COUNTY, STATE, AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CMS BUFFER SOLUTION PH 10.00, 061-648 5 GALLONS
CAGE:0B0Y1
CAGE:0B0Y1
============= Composition/Information on Ingredients =============
Ingred Name:BORIC ACID
CAS:10043-35-3
RTECS #:ED4550000
Fraction by Wt: <1%
OSHA PEL:10 MG/M3 (BORATES)
ACGIH TLV:5 MG/M3 (BORATES)
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: <1%
OSHA PEL:2 MG/M3, C
ACGIH TLV:2 MG/M3, C
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PYRAZOLE-3-CARBOXYLIC ACID,
5-HYDROXY-1-(P-SULFOPHENYL)-4-(P-SULFOPHENYL) AZO-, TRISODIUM SALT;
(FOOD COLORING)
CAS:1934-21-0
RTECS #:UQ6400000
Fraction by Wt: TRACE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BENZOIC ACID, P-HYDROXY-, METHYL ESTER; (METHYLPARABEN)
(INHIBITOR)
CAS:99-76-3
RTECS #:DH2450000
Fraction by Wt: TRACE
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT IS NOT EXPECTED TO PRESENT A
HEALTH HAZARD WHEN EMPLOYING GOOD LABORATORY PRACTICES.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . INGEST:INDUCE VOMITING OF CONSCIOUS PATIENT BY GIVING TWO
GLASSES OF WATER & PRESSING FINGER DOWN THROAT. CONTACT MD
IMMEDIATE LY. SKIN:REMOVE CONTAMINATED CLOTHING &WASH SKIN W/WATER.
IF IRRITATION PERSISTS, CONTACT MD. EYE:FLUSH W/WATER FOR AT LEAST
15 MINUTES. CONTACT MD IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN THE SPILL W/ABSORBENT MATERIAL OR MOP
UP W/WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NORMAL LABORATORY CARE.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:MECHANICAL (GENERAL).
Work Hygienic Practices:WASH W/SOAP & WATER AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:24
Spec Gravity:1 (H*2O=1)
Appearance and Odor:BLUE, ODORLESS SOLUTION.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE CARRIED OUT I/A/W FEDERAL,
STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:3980 ZF-1500+
CAGE:0U826
CAGE:0U826
CAGE:32204
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 75-85%
Ingred Name:EMULSION POLYMER
Fraction by Wt: 10-15%
Ingred Name:DIETHYLENE GLYCOL ETHYL ETHER, CARBITOL, CARBITOL
CELLOSOLVEETHOXY DIGLYCOL, 2-(2-ETHOXYETHOXY)-ETHANOL
CAS:111-90-0
RTECS #:KK8750000
Fraction by Wt: 3-5%
Ingred Name:TRIBUTOXYETHYL PHOSPHATE; ETHANOL, 2-BUTOXY-, PHOSPHATE
(3:1); KP 140; PHOSFLEX T-BEP
CAS:78-51-3
RTECS #:KJ9800000
Fraction by Wt: 1-5%
Ingred Name:DIPROPYLENE GLYCOL METHYL ETHER, DOWANOL DPM, DIPROPYLENE
GLYCOL MONOMETHYL ETHER
CAS:34590-94-8
RTECS #:JM1575000
Fraction by Wt: 1-3%
Other REC Limits:100 PPM
OSHA PEL:100 PPM SKIN
ACGIH TLV:606 MG/CUM
Ingred Name:ACRYLIC POLYMER
Fraction by Wt: 1-3%
Ingred Name:AMMONIUM HYDROXIDE, AQUA AMMONIA
CAS:1336-21-6
RTECS #:BQ9625000
Fraction by Wt: <0.5%
Other REC Limits:25 PPM
OSHA PEL:35 PPM
ACGIH TLV:25 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RATS): >5000 MG/KG
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:EYES: RINSE W/PLENTY OF WATER. SKIN: WASH W/SOAP & WATER.
INHALATION: REMOVE TO FRESH AIR. INGESTION: DRINK 1-2 GLASSES OF
WATER/MILK. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:NORMAL FIRE FIGHTING PROCEDURES MAY BE USED.
Unusual Fire/Explosion Hazard:NO SPECIAL HAZARDS KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/OIL-DRI/SIMILAR INERT MATERIAL.
SWEEP/SCRAPE UP & CONTAINERIZE. DON'T LET LEAKING MATERIAL ENTER
WATERCOURSE. MAY BE TOXIC TO AQUATIC LIFE. CONTAINS AMMONIA.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE W/ADEQUATE
VENTILATION.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL REQUIREMENTS UNDER LABEL RECOMMENDED
USE DIRECTIONS.
Ventilation:NO SPECIAL REQUIREMENTS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING. USE GOOD PERSONAL HYGIENE
PRACTICES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Melt/Freeze Pt:M.P/F.P Text:32F
Spec Gravity:1.02
pH:7.5-8
Solubility in Water:COMPLETE
Appearance and Odor:OPAQUE WHITE EMULSION W/MILD AMMONIA LIKE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NO SPECIAL REQUIREMENTS
==================== Disposal Considerations ====================
Waste Disposal Methods:NO SPECIAL METHOD. OBSERVE ALL APPLICABLE
FEDERAL, PROVINCIAL/STATE REGULATIONS & LOCAL/MUNICIPAL ORDINANCES
REGARDING DISPOSAL OF NON HAZARDOUS MATERIALS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:BTR 950 SEALANT (BULK GRADE)
CAGE:80318
CAGE:80318
============= Composition/Information on Ingredients =============
Ingred Name:POLYESTER RESIN
Fraction by Wt: 85-90%
Other REC Limits:NONE SPECIFIED
Ingred Name:TREATED CLAY
CAS:54351-63-2
Fraction by Wt: 10-15%
Other REC Limits:NONE SPECIFIED
Ingred Name:INHIBITORS
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS NOT AVAILABLE
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE:MAY BE MILDLY IRRITATING.
SKIN:RELEASE DURING HIGH PRESSURE USAGE MAY RESULT IN INJECTION OF
OIL INTO THE SKIN CAUSING LOCAL NECROSIS. INHALATION:NOT EXPECTED
TO BE A RELEVANT ROUTE OF EXPO SURE; HIGH TEMPERATURE VAPORS
IRRITATE RESPIRATORY TRACT. INGESTION:LOW LEVEL OF TOXICITY.
CHRONIC: SKIN DISORDERS.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:MAY CAUSE EYE, SKIN & RESPIRATORY TRACT
IRRITATION. LOCAL NECROSIS IS EVIDENCED BY DELAYED ONSET OF PAIN
AND TISSUE DAMAGE A FEW HOURS FOLLOWING INJECTION. EXPOSURE CAN
RESULT IN REDNESS AND TEARING O F EYES. INGESTION CAN CAUSE
GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING, AND DIARRHEA.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS MAY BE
AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN IF BREATHING IS
DIFFICULT. GET MEDICAL ATTENTION. EYE: FLUSH WITH WATER FOR 15
MINUTES WHILE HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION. SKIN:
WASH WITH S OAP & WATER/WATERLESS CLEANER. REMOVE CONTAMINATED
CLOTHING. IF IRRITATION PERSISTS, GET MEDICAL ATTENTION. INGESTION:
GET MEDICAL ADVICE AT ONCE.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>400F,>204C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP UP EXCESS GREASE. CLEAN AREA WITH
APPROPRIATE CLEANER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN
USE. KEEP AWAY FROM OPEN FLAMES & HIGH TEMPERATURES.
Other Precautions:MINIMIZE SKIN CONTACT. WASH WITH SOAP & WATER BEFORE
EATING, DRINKING, SMOKING OR USING TOILET FACILITIES. LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE. PROPERLY DISPOSE OF
CONTAMINATED LEATHER ARTICLES (SHOES) THAT CAN NOT BE
DECONTAMINATED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL(TLV), USE NIOSH/MSHA APPROVED RESPIRATORS AS
PER CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS. RESPIRATORY
PROTECTION NOT ORDINARILY R EQUIRED.
Ventilation:GENERAL MECHANICAL VENTILATION IN ACCORDANCE WITH GOOD
ENGINEERING PRACTICE.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
DO NOT GET IN EYES OR ON CLOTHING.
================== Physical/Chemical Properties ==================
HCC:V6
Vapor Pres:NEGLIGIBLE
Spec Gravity:1.10
Evaporation Rate & Reference:NEGLIGIBLE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TAN GREASE-LIKE MATERIAL; SLIGHT FATTY ODOR
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:A MIXTURE OF AIRBORNE SOLID, LIQUID
PARTICULATES AND GASES (CO) WILL EVOLVE WHEN THIS MATERIAL
UNDERGOES COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN AN APPROPRIATE DISPOSAL FACILITY
IN COMPLIANCE WITH LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TYPE A TONER P.C. 329621
CAGE:17980
CAGE:17980
============= Composition/Information on Ingredients =============
Ingred Name:ISOPAR G
CAS:6472-48-9
Fraction by Wt: >99%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT A CARCINOGEN.
Effects of Overexposure:INHALATION OF HIGH CONCENTRATIONS MAY HAVE
RESULTS RANGING FROM DIZZINESS AND HEADACHES TO UNCONSCIOUSNESS.
PROLONGED OR REPEATED LIQUID CONTACT WITH THE SKIN WILL DRY AND
DEFAT THE SKIN LEADING TO IR RITATION AND DERMATITIS.
Medical Cond Aggravated by Exposure:DERMATITIS.
======================= First Aid Measures =======================
First Aid:EYES-FLUSH WITH WATER FOR 15 MINUTES. SKIN-WASH WITH SOAP AND
WARM WATER. INHALATION-REMOVE TO FRESH AIR; CALL A PHYSICIAN.
INGESTION-DO NOT INDUCE VOMITING. CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:100F,38C
Lower Limits:0.8
Upper Limits:7.0
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE OR WATER FOG OR
SPRAY.
Fire Fighting Procedures:USE SUPPLIED AIR BREATHING EQUIPMENT FOR
ENCLOSED AREAS. COOL, EXPOSED CONTAINERS WITH WATER SPRAY. AVOID
BREATHING VAPORS OR FUMES.
Unusual Fire/Explosion Hazard:DO NOT MIX OR STORE WITH STRONG OXIDANTS
LIKE LIQUID CHLORINE OR CONCENTRATED OXYGEN. COMBUSTIBLE LIQUID.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. KEEP PEOPLE AWAY.
RECOVER FREE LIQUID. ADD ABSORBENT (SAND, EARTH, SAWDUST, ETC.) TO
SPILL AREA. AVOID BREATHING VAPORS. VENTILATE CONFINED SPACES. OPEN
ALL WINDOWS & DOOR S. KEEP PETROLEUM PRODUCTS OUT OF SEWERS &
WATERS.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT HANDLE OR STORE NEAR HEAT,
SPARKS, FLAME OR STRONG OXIDANTS. ADEQUATE VENTILATION REQUIRED.
Other Precautions:AVOID BREATHING VAPORS. AVOID PROLONGED OR REPEATED
CONTACT WITH SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE HYDROCARBON VAPOR CANISTER OR SUPPLIED-AIR
RESPIRATORY PROTECTION IN CONFINED OR ENCLOSED SPACES IF NEEDED.
Ventilation:LOCAL EXHAUST: FACE VELOCITY >60 FPM. MECHANICAL: USE
EXPLOSION PROOF EQUIPMENT. USE ONLY WITH ADEQUATE VENTILATION.
Other Protective Equipment:USE CHEMICAL RESISTANT APRON OR OTHER
CLOTHING IF NEEDED TO AVOID REPEATED OR PROLONGED SKIN CONTACT.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING, LAUNDER BEFORE
REUSE. REMOVE CONTAMINATED SHOES & DRY BEFORE REUSE. WASH UP AFTER
CONTACT.
Supplemental Safety and Health
COMBUSTIBLE LIQUID.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:157-176C
Vapor Pres:10
Vapor Density:5.0
Spec Gravity:0.75
Evaporation Rate & Reference:0.3
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK LIQUID. MILD ISOPARAFFINIC ODOR.
Percent Volatiles by Volume:99
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS LIKE: LIQUID CHLORINE, CONCENTRATED OXYGEN, SODIUM OR
CALCIUM HYPOCHLORITES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:FUMES, SMOKE AND CARBON MONOXIDE, IN
THE CASE OF INCOMPLETE COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:ASSURE CONFORMITY WITH APPLICABLE DISPOSAL
REGULATIONS. DISPOSE OF ABSORBED MATERIAL AT AN APPROVED DISPOSAL
SITE OR FACILITY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:WONDER-TONES 3801 WHITE INTERIOR ACRYLIC LATEX (SUP DATA)
CAGE:HO643
CAGE:HO643
CAGE:6R552
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 40-60%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACRYLIC RESIN
Fraction by Wt: 25%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 3-25%
Other REC Limits:10 MG/M*3
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:PROPYLENE GLYCOL
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: 3-10%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS AND SYMPTOMS OF OVEREXPOSURE
Explanation of Carcinogenicity:NONE
Effects of Overexposure:ACUTE-BREATHING: IRRITATION OF THE RESPIRATORY
TRACT; HEADACHE, NAUSEA, DIZZINESS. SKIN OR EYE CONTACT: PRIMARY
IRRITATION. CHRONIC-PROLONGED AND REPEATED BREATHING OF SPRAY MIST
AND/OR SANDING DUST O VER A PERIOD OF YEARS MAY CAUSE DUST DISEASE
OF THE LUNGS.
Medical Cond Aggravated by Exposure:NONE WHEN USED IN ACCORDANCE WITH
SAFE HANDLING AND USE INFORMATION.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. EYES: FLUSH IMMEDIATELY WITH
LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. CONSULT A PHYSICIAN
FOR MEDICAL TREATMENT. SKIN: REMOVEWITH SOAP AND WATER. REMOVE
SOILED CLOTH ING. INGEST: DRINK 1 OR 2 GLASSES OF WATER TO DILUTE.
DO NOT INDUCE VOMITING. CONSULT PHYSICIAN IMMEDIATELY. TREAT
SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:N/K
Upper Limits:N/K
Extinguishing Media:IN CASE OF FIRE USE CO*2, DRY CHEMICAL, FOAM OR
OTHER (NFPA) APPROVED METHOD FORTREATING A CLASS B FIRE.
Fire Fighting Procedures:USE FULL PROT EQUIP INCLUDING SCBA. H*2OSPRAY
MAY BE INEFFECTIVE. H*2O USED, FOGNOZZLES PREFERABLE. H*2O USED TO
COOL CLOSED CONTR + PVNT PRESS BUILD-UP.
Unusual Fire/Explosion Hazard:DUE TO PRESS BUILD-UP, CLOSED CONTR EXPOS
TO EXTREME HEAT MAY EXPLODE. OVEREXPOSTO DECOMP PROD MAY CAUSE HLTH
HAZ. SYMP NOT READY APPARENT. OBTAIN MED ATTEN.
================== Accidental Release Measures ==================
Spill Release Procedures:WASH WITH WATER. BEFORE ATTEMPTING CLEAN-UP,
REFER TO HAZARD CAUTION INFORMATIONIN OTHER SECTIONS OF THIS MSDS.
CONTAIN SPILLED MATERIAL AND REMOVE WITH INERT ABSORBENT. STORE IN
CLOSED CONTAINER UNTI L PROPERLY DISPOSED OF.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 110 F AND KEEP FROM
FREEZING. KEEP CONTAINER CLOSED WHEN NOT IN USE.DO NOT REUSE EMPTY
CONTAINERS. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:N/K
============= Exposure Controls/Personal Protection =============
Respiratory Protection:OUTDOOR/OPEN AREA USE NIOSH/MSHA MECHANICAL
FILTER. RESTRICTED VENTILATION USE NIOSH/MSHA CHEMICAL/MECHANICAL
FILTER. USE IN CONFINED AREA WEAR NIOSH/MSHA AIR SUPPLY RESPIRATOR
OR HOOD. USE NIOSH/MSHA RESP WHEN FLAME CUT, WELD, BRAZ, SAND.
Ventilation:PROVIDE GEN DILUTION OR LOCAL EXHAUST VENT IN VOLUME +
PATTERN TO KEEP AIR CONTAM CONC BELOW CURRENT APPLIC (SUP DATA)
Other Protective Equipment:NOT REQUIRED
Work Hygienic Practices:REMOVE AND WASH SOILED CLOTHING BEFORE REUSE.
WASH HANDS BEFORE EATING OR USING THE WASHROOM.
Supplemental Safety and Health
PART NO: SEMI-GLOSS ENAMEL. % VOLAT 70.1.MFR STATE NH*3 IN PROD, UNK
CONC. VAP DENS: FOR SOLVENT, NH*3 + H*2O-LIGHT THANAIR, PROPYLENE
GLYCOL-HEAV THAN AIR. VENT: SAFETY + HLTH STD IN MIX, APPLICATN +
CURING AREA, REMOVE SAND DUST, DRIED COAT + DECOMP PROD DURING
WELD, FLAME CUT, ON SURFACE COAT W/ MAT. LB/GAL:8.07-1.03
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212-369 F
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/K
Vapor Density:SUP DATA
Spec Gravity:1.03-1.25
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:N/K
Appearance and Odor:N/K
Percent Volatiles by Volume:61.4
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
N/K
Stability Condition to Avoid:N/K
Hazardous Decomposition Products:FUMES MAY CONTAIN CARBON MONOXIDE,
CARBON DIOXIDE, OXIDES OF NITROGEN AND OXIDESOF METALS LISTED IN
INGREDIENT SECTION.
Conditions to Avoid Polymerization:WILL NOT OCCUR
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. INCINERATE ONLY IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SHOFU LINING CEMENT LIQUID
CAGE:9K743
CAGE:9K743
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS FOR INGREDIENTS
Fraction by Wt: 100%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: CAUSE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN/EYES: CAUSE IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/FLOWING WATER. CONSULT PHYSICIAN IF ECESSARY.
SKIN: WASH AREA W/MILD SOAP & WATER. INGESTION: DRINK W/PLENTY OF
WATER. CONSULT PHYSICIAN IF NECESSARY.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP & DISCARD IN A SUITABLE CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL AREA W/LID TIGHTLY
CLOSED. HANDLING OF PRODUCT EXCLUSIVELY BY DENTAL SPECIALISTS
ACCORDING TO INSTRUCTIONS FOR USE.
Other Precautions:AVOID CONTACT W/SKIN & EYES.
============= Exposure Controls/Personal Protection =============
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:<1.0
Evaporation Rate & Reference:(BU AC = 1): >1.0
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS, VISCOUS LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PASTELS WOOD STAIN, SLATE BLUE, 803
CAGE:0K1A4
CAGE:0K1A4
============= Composition/Information on Ingredients =============
Ingred Name:MEDIUM ALIPHATIC SOLVENT NAPHTHA (PETROLEUM); (MINERAL
SPIRITS) VP: 2
CAS:64742-88-7
= Wt:40.
Ingred Name:COBALT NAPHTHENATES VP: 0
CAS:61789-51-3
RTECS #:QK8925000
= Wt:.1
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EXPOS MAY BE BY INHAL &/OR SKIN OR EYE
CONTACT, DEPENDING ON CNDTNS OF USE. TO MINIMIZE EXPOS, FOLLOW
RECOMS FOR PROPER USE, VENT & PERSONAL PROT EQUIP. ACUTE: IRRIT OF
EYES, SKIN & RESP SYSTEM. MAY C AUSE NERVOUS SYSTEM DEPRESSION.
EXTREME OVEREXP MAY RESULT IN UNCONSCIOUSNESS & POSSIBLY DEATH.
HEADACHE, DIZZINESS, NAUSEA & LOSS OF COORD ARE INDICATIONS OF
EXCESSIVE EXPOS TO VAPS OR SPRAY MISTS. R EDNESS & ITCHING OR
BURNING SENSATION MAY INDICATE EYE OR EXCESSIVE SKIN EXPOSURE.
CHRONIC: COBALT & COBALT CMPDS ARE CLASSIFIED BY IARC AS POSSIBLY
CARCINOGENIC TO HUMANS (GROUP 2B) BASED ON EXPERIME NTAL ANIMAL
DATA, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:COBALT NAPHTHENATE: IARC MONOGRAPHS, VOL
52, PG 363, 1991:GROUP 2B.
Effects of Overexposure:EFTS OF OVEREXP: HOWEVER, THERE IS INADEQUATE
EVIDENCE IN HUMANS FOR ITS CARCINOGENICITY. PRLNGD OVEREXP TO
SOLVENT INGREDIENTS LISTED IN INGREDIENT SECTION MAY CAUSE ADVERSE
EFFECTS TO THE LIVER & UR INARY SYSTEMS. RATS EXPOSED TO TITANIUM
DIOXIDE DUST AT 250 MG/M3 DEVELOPED LUNG CANCER, HOWEVER, SUCH
EXPOSURE LEVELS ARE NOT ATTAINABLE IN THE WORKPLACE. REPORTS HAVE
ASSOCIATED RPTD & PRLNGD OVEREX P TO SOLVENTS W/PERMANENT BRAIN &
NERVOUS SYSTEM DAMAGE.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHALATION: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE
BREATHING. KEEP WARM AND QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY
WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER
BEFORE REUSE. E YES: FLUSH EYES WITH LARGE AMOUNTS OF WATER FOR AT
LEAST 15 MINUTES. GET MEDICAL ATTENTION. INGESTION: GET MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:=40.C, 104.F
Lower Limits:1.0%
Upper Limits:12.5%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL FOAM.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLESS ARE
PREFERABLE. WATER MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT
PRESSURE BUILD-UP & POSSIBLE AUTOIGNITION OR EXPLOSION WHEN
EXPOSED TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO THE
BUILD-UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT. FLAMMABILITY
CLASSIFICATION: COMBUSTIBLE, FLASH ABOVE 99 AND BELOW 200F.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:DOL STORAGE CATEGORY: 2. CONTENTS ARE
COMBUSTIBLE. KEEP AWAY FROM HEAT & OPEN FLAME. CONSULT NFPA CODE.
USE APPRVD BONDING & GROUNDING PROCEDURES. KEEP CNTNR CLOSED WHEN
NOT IN USE. TRANSFER ONLY TO A PPRVD CNTNRS W/COMPLETE & APPROP
LABELING. DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:INTENTIONAL MISUSE BY DELIB CONCENTRATING & INHALING
CONTENTS CAN BE HARMFUL/FATAL. USE ONLY W/ADEQ VENT. AVOID BRTHG
VAP & SPRAY MIST. AVOID CNTCT W/SKIN & EYES. WASH HANDS AFTER
USING. THIS COATING MAY CONTAIN MATLS CLASSIFIED AS NUISANCE
PARTICULATES (LISTED "AS DUST" IN INGRED SECTION) WHICH MAY BE
PRESENT (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIMITS BY VENT, WEAR PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESP APPRVD BY NIOSH FOR PROT AGAINST MATLS
LISTED. WHEN SANDING/ABRADING DRIED FILM, WEAR DUST/MIST RESP
APPRVD BY NIOSH FOR DUST WHICH MAY BE GENERATED FROM PROD,
UNDERLYING PAINT OR THE ABRASIVE.
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPTABLE IF EXPOS TO LISTED
MATLS IS MAINTAINED BELOW APPLIC EXPOS LIMS. REFER TO OSHA STDS
1910.94, 1910.107, 1910.108.
Other Protective Equipment:ANSI APPROVED EYE WASH AND DELUGE SHOWER .
Supplemental Safety and Health
OTHER PRECS: AT HAZ LEVELS ONLY DURING SANDING OR ABRADING OF DRIED
FILM. IF NO SPECIFIC DUSTS ARE LISTED, APPLIC LIMS FOR NUISANCE
DUSTS ARE ACGIH TLV 10 MG/M3 (TDUST), 3 MG/M3 (RESPIRABLE
FRACTION),OSHA PEL 15 MG/M3 (TDUST), 5 MG/M3 (RESPIRABLE
FRACTION).
================== Physical/Chemical Properties ==================
Boiling Pt:>100.C, 212.F
B.P. Text:212-395F
Vapor Pres:SEE INGREDS
Vapor Density:HVR/AIR
Spec Gravity:1.05
VOC Pounds/Gallon:530
VOC Grams/Liter:4.42
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:74
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE.
===================== Ecological Information =====================
Ecological:ENVIRONMENTAL FATE: NO INFORMATION FOUND. EVNIRONMENTAL
TOXICITY: NO INFORMATION FOUND.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THIS PROD MAY BE HAZARDOUS AS DEFINED
UNDER THE RESOURCE CONSERVATION & RECOVERY ACT (RCRA) 40 CFR 261.
WASTE MUST BE TESTED FOR IGNITABILITY TO DETERM APPLIC EPA HAZ
WASTE NUMBERS. INCIN I N APPRVD FACILITY. DO NOT INCIN CLOSED
CNTNRS. DISPOSE OF I/A/W FED, STATE & LOCAL REGS REGARDING PO
LLUTION.
=================== MSDS Transport Information ===================
Transport Information:NOT REGULATED.
===================== Regulatory Information =====================
SARA Title III Information:SARA 313 (40 CFR 372.65C) SUPPLIER
NOTIFICATION: COBALT COMPOUND - 0.2% BY WT; 0.1% ELEMENT.
Federal Regulatory Information:TSCA CERTIFICATION: ALL CHEMICALS IN
THIS PRODUCT ARE LISTED, OR ARE EXEMPT FROM LISTING, ON THE TSCA
INVENTORY.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SELENIUM DIOXIDE
Preparer's Name:E BRULL
CAGE:63415
CAGE:63415
============= Composition/Information on Ingredients =============
Ingred Name:SELENIUM (IV) OXIDE, SELENIUM DIOXIDE
CAS:7446-08-4
RTECS #:VS8575000
Fraction by Wt: 100%
Other REC Limits:0.2 MG/CUM
ACGIH TLV:0.2 MG/CUM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 6750 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SUBSTANCE IS TOXIC TO BLOOD, KIDNEYS,
LUNGS, LIVER & MUCOUS MEMBRANES. SKIN/EYES: CORROSIVE. INHALATION:
IRRITATION TO GI/RESPIRATORY TRACT. SEVERE OVER-EXPOSURE CAN
PRODUCE LUNG DAMAGE, CHOKING, UNCO NSCIOUSNESS/DEATH. FATAL IF
INHALED/INGESTED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, CORNEAL DAMAGE/BLINDNESS,
INFLAMMATION, BLISTERING, BURNING, SNEEZING, COUGH, REDNESS,
WATERING, ITCHING, SCALING.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/WATER FOR 15 MINS. DON'T USE
OINTMENTS. SKIN: PLACE VICTIM UNDER A DELUGE SHOWER. GENTLY &
THOROUGHLY WASH W/RUNNING WATER & NON-ABRASIVE SOAP. CLEAN FOLDS,
CREVICES & GROIN. USE COLD WATER. WASH W/DISINFECTANT SOAP & COVER
W/ANTI-BACTERIAL CREAM. INHALATION: REMOVE TO FRESH AIR. LOOSEN
TIGHT CLOTHING. GIVE CPR/OXYGEN IF NEEDED. WARNING: (SEE SUPP)
===================== Fire Fighting Measures =====================
Unusual Fire/Explosion Hazard:NON-FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: USE APPROPRIATE TOOLS TO PUT SOLID IN
CONVENIENT WASTE DISPOSAL CONTAINER. LARGE: CORROSIVE & POISONOUS
SOLID. STOP LEAK, SAFELY. DON'T GET WATER INSIDE CONTAINER. DON'T
TOUCH. USE WATER SPRAY TO REDUCE VAPORS. (SEE SUPP)
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP LOCKED UP. KEEP CONTAINER DRY.
DON'T INGEST/BREATHE DUST. NEVER ADD WATER. WEAR SUITABLE
RESPIRATORY EQUIPMENT.
Other Precautions:CORROSIVE & SHOULD BE STORED IN SEPARATE SAFETY
STORAGE CABINET/ROOM. AVOID CONTACT W/SKIN & EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR/EQUIVALENT.
VAPOR & DUST RESPIRATOR. A SCBA, TO AVOID INHALATION OF THE
PRODUCT.
Ventilation:LOCAL EXHAUST VENTILATION TO KEEP AIRBORNE LEVELS BELOW
EXPOSURE LIMITS.
Other Protective Equipment:SYNTHETIC APRON, FULL SUIT, BOOTS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
FIRST AID CONT'D: IT MAY BE DANGEROUS TO PERSON PROVIDING AID TO GIVE
MOUTH-TO-MOUTH RESUSCITATION WHEN INHALED MATERIAL IS TOXIC,
INFECTIOUS/CORROSIVE. INGESTION: DON'T INDUCE VOMITING. GIVE
WATER/MI LK. OBTAIN MEDICAL ATTENTION IN ALL CASES. SPILLS CONT'D:
AVOID ENTRY TO SEWERS, BASEMENTS/CONFINED AREAS. DIKE.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:SUBLIME
Vapor Pres:0.001
Spec Gravity:3.954
Solubility in Water:SOLUBLE (COLD WATER)
Appearance and Odor:WHITE TO REDDISH LUSTROUS SOLID W/ACID TASTE & SOUR
ODOR.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:RECYCLE TO PROCESS, IF POSSIBLE. DISPOSE OF
IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
NIIN: 01-228-5646
Product ID: CARBON DIOXIDE, GAS
Cage: 2W134
Box: 382
=======================================================
Contractor Summary
=======================================================
Cage: 1CU83
Box: 10606
Cage: 2W134
=======================================================
Item Description Information
=======================================================
Item Manager: S9I
Item Name: CARTRIDGE,INFLATOR,FLOTATION GEAR
Specification Number: UNKNOWN
Unit of Issue: EA
UI Container Qty: 0
Type of Container: CARTRIDGE
=======================================================
Ingredients
=======================================================
Cas: 124-38-9
RTECS #: FF6400000
% Wt: 100.0
Other REC Limits: NONE RECOMMENDED
OSHA PEL: .000 PPM
ACGIH TLV: 5000PPM/30000STEL;96
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHAL:SIMPLE ASPHYXIANTS.HYPOVENTILATION,RESP
SOIDOSIS,DEATH FROM ASPHYXIA.SKIN:NO ADVERSE EFFECTS FROM GAS.DUE TO RAPID
EVAPORATION LIQ MAY CAUSE FROSTBITE,W/RED,TINGLING,PAIN,NUMBNESS,SKIN BECOME
HA RD,WHITE,DEVELOP BLISTERS.EYE:STINGING SENS,IRRIT.INGEST:UNLIKELY.LIQ
INGEST FROSTBITE TO LIPS/MOUTH/MUC MEMB MAY OCCUR.
Explanation Of Carcinogenicity: PER MSDS:CARCINOGEN STATUS:NONE.
Signs And Symptions Of Overexposure: SIMPLE ASPHYXIANTS, HYPOVENTILATION,
RESPIRATORY SOIDOSIS, DEATH. FROSTBITE W/REDNESS,TINGLING,PAIN,NUMBNESS,SKIN
HARD & WHITE,DEVELOP BLISTERS. STINGING EYE SENSATION,IRRIT. FROSTBITE OF
LIPS/MOUTH/M UC MEMB MAY OCCUR.
Medical Cond Aggravated By Exposure: TARGET EFFECTS:SIMPLE ASPHYXIANT.POISONING
MAY AFFECT HEART,RESP & NERVOUS SYSTEM.
First Aid: INHAL:IMMED REMOVE FROM EXPO AREA TO FRESH AIR.BREATH STOP GIVE ART
RESP.MAINTAIN AIRWAY & BLOOD PRESSURE.KEEP AFFECTED PERSON WARM.GETMED
ATTN IMMED. SKIN:FROSTBITE WARM AFFECTED SKIN IN WARM WATER(1 07F).WARM WATER
UNAVAIL GENTLY WRAP AFFECTED AREA IN BLANKETS.ALLOW CIRCULA RETURN
NATURALLY.GET MED ATTN IMMED. EYE:WASH W/LG AMTS OF WARM WATER APPROX
15-20MINS.GET MED ATTN IMMED. INGEST:(SUPPLEME)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: FOR ASSISTANCE CONTACT DISTRICT DIRECTOR OF EPA.
Handling And Storage Precautions: STORE IAW 29CFR 1910.101.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: DRY CHEMICAL, CARBON DIOXIDE, HALON. FOR LG FIRES USE
WATER SPRAY, FOG OR STD FOAM.
Fire Fighting Procedures: COOL FIRE-EXPO CYL W/WATER FORM SIDE TIL WELL AFAT
FIRE IS OUT.USE AENTS SUITABLE FOR TYPE OF FIRE.COOL CYL W/FLOODING AMTS OF
WATER APPLIED FROM AS FAR (SUPPL)
Unusual Fire/Explosion Hazard: GAS-NEGLIGIBLE FIRE HAZARD WHEN EXPO TO
HEAT/FLAME.CYL-MAY EXPLO IN HEAT OF FIRE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: ANY SELF-CONTAINED BREATHING APPARATUS.
Ventilation: PROVIDE GENERAL DILUTION VENTILATION.
Other Protective Equipment: PROTECTIVE CLOTHING IS NOT REQUIRED.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: PH:ACIDIC IN SOLN. FIREFIGHT:A DISTANCE AS
POSSIBLE. CONDITIONS TO AVOID:OF LIQUEFIED GASES W/WATER MAY CAUSE EXPLO DUE
TO RAPID TEMP FLUCTUATIONS. 1STAID:TREAT SYMPTOMATICALLY.GET MED ATTN.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: G2
B.P. Text: -109F,-78C
M.P/F.P Text: -71F,-57C
Decomp Text: >3092F,>170
Vapor Pres: 43700 @21C
Vapor Density: 1.977 @0C
Spec Gravity: 1.52 @21C
PH: SUPPLE
Solubility in Water: SOLUBLE.
Appearance and Odor: ODORLESS, COLORLESS GAS WITH SLIGHT ACIDIC TASTE.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: DON'T PERMIT PHY DMG/OVERHEAT OF CYL.CONTENTS
UNDER PRESSURE;CYL MAY RUPTURE-TRAVEL CONSIDERABLE DISTANCE.CONTACT(SUPPL)
Materials To Avoid: ACRYALDEHYDE,BAO2,CS2O,DIETHYL
MAGNASIUM,ETHYLENEIMINE,HYDRAZLINE,METAL ACETYLIDES/HYDRIDES,METALS,K,K-NA
ALLOY,NA,NA2O2
Hazardous Decomposition Products: TEMP >1700C MAY CAUSE DECOMPO & RELEAASE
OXYGEN & HIGHLY TOXIC CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 116592
Product ID: CARBON DIOXIDE, GAS
Review Date: 11/06/1996
Net Unit Weight: 25 GRAMS
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: EA
Container QTY: 0
Type Of Container: CARTRIDGE
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: DQQ
Symbols: G
DOT Proper Shipping Name: COMPRESSED GASES, N.O.S.
Hazard Class: 2.2
UN ID Num: UN1956
Label: NONFLAMMABLE GAS
Special Provision: B13
Non Bulk Pack: 302,305
Bulk Pack: 314,315
Max Qty Pass: 75 KG
Max Qty Cargo: 150 KG
Vessel Stow Req: A
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: EQH
IMO Proper Shipping Name: COMPRESSED GAS, N.O.S. o
IMDG Page Number: 2124
UN Number: 1956
UN Hazard Class: 2(2.2)
IMO Packaging Group: -
Subsidiary Risk Label: -
EMS Number: 2-04
MED First Aid Guide NUM: 620
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: HDO
IATA UN ID Num: 1956
IATA Proper Shipping Name: COMPRESSED GAS, N.O.S. *
IATA UN Class: 2.2
IATA Label: NON-FLAMMABLE GAS
Packing Note Passenger: 200
Max Quant Pass: 75KG
Max Quant Cargo: 150KG
Packaging Note Cargo: 200
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: HDO
AFI Symbols: *
AFI Proper Shipping Name: COMPRESSED GAS, N.O.S.
AFI Hazard Class: 2.2
AFI UN ID NUM: UN1956
Special Provisions: P5
Back Pack Reference: A6.3, A6.5,A6.6
=======================================================
HAZCOM Label
=======================================================
Product ID: CARBON DIOXIDE, GAS
Cage: 2W134
Company Name: LELAND LTD INC
Street: 2614 S CLINTON AVE
Zipcode: 07080
Label Required IND: Y
Date Of Label Review: 11/06/1996
Status Code: C
Label Date: 11/06/1996
Origination Code: F
Chronic Hazard IND: Y
Signal Word: CAUTION
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: INHAL:SIMPLE ASPHYXIANTS.HYPOVENTI,RESP SOIDOSIS,DEATH
FROM ASPHYXIA.SKIN:NO ADVERSE EFFECTS FROM GAS.DUE TO RAPID EVAPO LIQ MAY
CAUSE FROSTBITE,W/RED,TINGL,PAIN,NUMB,SKIN HARD,WHITE,BLISTERS.EYE:STIN G
SENS,IRRIT.INGEST:UNLIKELY.LIQ INGESTFROSTBITE TO LIPS/MOUTH/MUC MEMB MAY
OCCUR.1STAID:INHAL:IMMED MOVE TO FRESH AIR.BREATH STOP GIVE ART RESP.MAINTAIN
AIRWAY/BLOOD PRESSURE.KEEP WARM.GET MED ATTN I MMED.SKIN:FROSTBITE WARM
AFFECTED SKIN IN WARM WATER(107F);NOT UNAVAIL GENTLY WRAP AFFECTED AREA IN
BLANKETS.ALLOW CIRCULA RETURN NATURALLY.GET MED ATTN IMMED.EYE:WASH W/LG AMTS
OF WARM WATER APPROX 1 5-20MINS.GET MED ATTN IMMED.INGEST:TREAT SYMPT/SU
=======================================================
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:30796 CLEANER
CAGE:53472
CAGE:IO629
CAGE:53472
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ETHYL KETONE
CAS:78-93-3
RTECS #:EL6475000
Minumum % Wt:85.
Maxumum % Wt:96.
Other REC Limits:N/K
OSHA PEL:590 MG/M3;200 PPM
OSHA STEL:885 MG/M3;300 PPM
ACGIH TLV:590 MG/M3;200 PPM
ACGIH STEL:885 MG/M3;300 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETONE
CAS:67-64-1
RTECS #:AL3150000
Minumum % Wt:1.
Maxumum % Wt:10.
Other REC Limits:N/K
OSHA PEL:2400 MG/M3;1000 PPM
OSHA STEL:1800 MG/M3;750 PPM
ACGIH TLV:1780 MG/M3;750 PPM
ACGIH STEL:2380 MG/M3;1000 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE IRRITATION OF
MUCOUS MEMBRANES, NOSE & THROAT, HEADACHE, DIZZINESS, NAUSEA,
NUMBNESS OF EXTREMITIES & NARCOSIS IN HIGH CONCENTRATIONS. HAS
CAUSED CNS DEPRESSION & LIVER DAMAGE IN ANIMALS & CONCENTRATIONS
OF 1000-3000 PPM CAUSED RETARDATION OF FETAL DEVELOPMENT IN RATS.
SKIN: CHRONIC CONTACT MAY LEAD TO IRRITATION & DERMATITIS. CHRONIC
EXPOSURE TO VAPORS OF HIGH CONCENTRATIONS MAY CAUSE DERMATITIS.
MAY POSSIBLY BE ABSORBED THROUGH SKIN. EYES: VAPORS/DIRECT CONTACT
MAY CAUSE IRRITATION. INGESTION: MAY BE ASPIRATED INTO LUNGS/CAUSE
SYSTEMIC EFFECTS DESCRIBED UNDER INHALATION . TARGET ORGANS: EYES,
SKIN, LUNGS, CNS.
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:SKIN: IF IRRITATION ARISES, WASH THOROUGHLY WITH SOAP AND
WATER. SEEK MEDICAL ATTENTION IF IRRITATION PERSISTS. EYES: IF
FUMES CAUSE IRRITATION, MOVE TO FRESH AIR AND IRRIGATE EYES WITH
WATER FOR AT L EAST 15 MINUTES. IF IRRITATION PERSISTS, SEEK
MEDICAL ATTENTION. INHALATION: MOVE TO FRESH AIR. IF BREATHING IS
DIFFICULT, GIVE OXYGEN. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION. KEEP VICTIM QUIET AND WARM. CALL A POISON CONTROL
CENTER OR PHYSICIAN IMMEDIATELY. INGESTION: DRINK WATER AND CALL A
POISON CONTROL CENTER OR PHYSICIAN IMMEDIATELY. AVOID ALCOHOLIC
BEVERAGES. NEVER GIVE ANYTHING BY MO UTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>-17.6C, 0.F
0F - 3F
Lower Limits:2.15%
Upper Limits:13.0%
Extinguishing Media:FOR SMALL FIRES: USE DRY CHEMICAL, CARBON DIOXIDE,
WATER OR FOAM EXTINGUISHER.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . FOR LARGE FIRES, EVACUATE AREA AND CALL FIRE DEPARTMENT
IMMEDIATELY.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA, STOP LEAK IF IT CAN BE DONE
WITHOUT RISK. TAKE UP WITH SAND, EARTH OR OTHER NON-COMBUSTIBLE
ABSORBING MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS AND
FLAMES; STORE IN COOL, DRY PLACE.
Other Precautions:CONTAINERS, EVEN EMPTIES WILL RETAIN RESIDUE AND
VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED CANNISTER RESPIRATOR IN
ABSENCE OF ADEQUATE VENTILATION.
Ventilation:GEN MECH: EXHST VENT CAPABLE OF MAINTAINING EMISSIONS AT
POINT OF USE BELOW PEL. LOCAL EXHST: OPEN DOORS & WINDOWS. IF USED
IN ENCLSD AREAS, USE EXHST FANS.
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA .
Supplemental Safety and Health
PHYSICAL/CHEMICAL PROPERTIES: VOLATILES COMPONENTS: 100%; WILL DISSOLVE
IN WATER, ORGANIC SOLVENTS.
================== Physical/Chemical Properties ==================
Boiling Pt:=56.1C, 133.F
Vapor Pres:186 MMHG @ 20C
Vapor Density:2.0(AIR=1)
Spec Gravity:0.793
Evaporation Rate & Reference:7.7 (BUTYL ACETATE=1)
Solubility in Water:27.1% WT @ 20C
Appearance and Odor:COLORLESS LIQUID; SHARP, PENETRATING ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, OXIDIZING MATERIALS, ALKALIS, CHLORINATED INORGANICS (POTASSIUM,
CALCIUM AND SODIUM HYPOCHLORITE), COPPER OR COPPER ALLOYS.
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
HYDROGEN CHLORIDE, SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL, STATE AND FEDERAL
REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:DOT PROPER SHIPPING NAME: CONSUMER COMMODITY
ORM-D; CLEANING COMPOUND. DOT HAZARD CLASS: NOT APPLICABLE.
SHIPPING ID NUMBER: NOT APPLICABLE.
===================== Regulatory Information =====================
Federal Regulatory Information:EPA HAZARDOUS WASTE ID NUMBER: F-005.
EPA HAZARD WASTE CLASS: IGNITABLE WASTE/TOXIC WASTE. KNOWN HAZARDS
UNDER 29 CFR 1910.1200: FLAMMABLE LIQUID, IRRITANT, SKIN HAZARD,
EYE HAZARD, TOXIC AGENT, REPRO DUCTIVE TOXIN, NERVOUS SYSTEM TOXIN,
LUNG TOXIN.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MIL-L-23699D;TURBINE LUBRICANT
Preparer's Name:N.R.NETZEL
CAGE:VELSI
CAGE:0Z6C4
CAGE:VELSI
============= Composition/Information on Ingredients =============
Ingred Name:POLYOL ESTER
Other REC Limits:NONE RECOMMENDED
Ingred Name:TRICRESYLPHOSPHATE
CAS:1330-78-5
RTECS #:TD0175000
Fraction by Wt: 1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV FOR OIL MIST IS 5MG/M3
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:MAY CAUSE IRRITATION.SKIN:MAY
CAUSE IRRITATION.INGEST:MAY CAUSE NERVIOUS SYSTEM EFFECTS BASED ON
ANIMAL TESTING.INHAL:MAY CAUSE RESPIRATORY IRRITATION.
Explanation of Carcinogenicity:NONE OF THE INGREDIENTS IN THIS PRODUCT
IS LISTED BY NTP, IARC OR OSHA AS A CARCINOGEN.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH SOAP AND
WATER.EYES:FLUSH WITH WATER FOR 15 MINUTES.CALL PHYSICIAN IF
IRRITATION DEVELOPS.INHAL:REMOVE TO FRESH AIR.GIVE OXYGEN OR
ARTIFICIAL RESPIRATION IF NEEDED.INGEST:DO NOT INDUCE VOMITING.GET
PROMPT QUALIFIED MEDICAL ATTENTION.NOTE TO PHYSICIAN:TREAT
SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>450F,>232C
Extinguishing Media:WATER FOG,DRY CHEMICAL,CARBON DIOXIDE,FOAM.AVOID
SPREADING BURNING LIQUID WITH WATER STREAM.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.HEAT OF FIRE MAY CAUSE
CONTAINERS TO BURST.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP WITH NON-COMBUSTIBLE INERT
ADSORBANT(EG.CLAY);PLACE COLLECTED MATERIAL IN AN APPROPRIATE
CONTAINER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY,WELL-VENTILATED
PLACE.KEEP CONTAINER CLOSED WHEN NOT IN USE.KEEP AWAY FROM
HEAT,SPARKS,FLAMES AND STRONG OXIDIZERS.
Other Precautions:AVOID EYE AND SKIN CONTACT. DO NOT BREATHE VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. NIOSH/MSHA-APPROVED
RESPIRATOR OR SCBA AS APPROPIATE FOR EXPOSURE OF CONCERN.
Ventilation:NO SPECIAL REQUIREMENTS.
Other Protective Equipment:PROVIDE A LOCAL EYE WASH STATION AND SAFETY
SHOWER.
Work Hygienic Practices:WASH HANDS.SEPERATE WORK CLOTHES FROM STREET
CLOTHES.LAUNDER WORK CLOTHES BEFORE REUSE.KEEP FOOD OUT OF THE WORK
AREA.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:>520F,>271C
Vapor Density:>1
Spec Gravity:1
Evaporation Rate & Reference:NOT VOLATILE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR LIQUID,MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH HEAT,SOURCES OF IGNITION.
Hazardous Decomposition Products:UNIDENTIFIED TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL,STATE AND LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:Q17CR016 809 FISHEYE ELIMINATOR
CAGE:70526
CAGE:70526
CAGE:BASSF
============= Composition/Information on Ingredients =============
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *95-1*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 94%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOLATILE ORGANIC COMPOUNDS: 821.8 G/L
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: ANESTHETIC. IRRITATION OF
RESPIRATORY TRACT/ACUTE NERVOUS SYSTEM DEPRSSION. MISUSE BY
CONCENTRATING & INHALING THE CONTENTS MAY BE HARMFUL/FATAL.
INGESTION: GI IRRITATION. ASPIRATION OF MA TERIAL INTO LUNGS MAY
RESULT IN CHEMICAL PNEUMONITIS WHICH CAN BE FATAL. SKIN: IRRITATION
& ABSORPTION. EYES: IRRITATION
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHES, NAUSEA, LOSS OF
CONSCIOUSNESS, VOMITING.
======================= First Aid Measures =======================
First Aid:INHALATION: RESTORE BREATHING. REMOVE TO FRESH AIR. KEEP WARM
& QUIET. EYES: FLUSH IMMEDIATELY W/COPIOUS AMOUNTS OF RUNNING WATER
FOR 15 MINS. SKIN: CLEAN & WASH AFFECTED AREA W/WATER. INGESTION:
ASPI RATION HAZARD. DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION
IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:5F
Lower Limits:1
Upper Limits:7
Extinguishing Media:FOAM, CO2, CHEMICAL POWDER
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIPMENT & SCBA. WATER
SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE.(SUPP
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE ALL POSSIBLE SOURCES OF
IGNITION. AVOID PROLONGED BREATHING OF VAPORS. CONFINE W/INERT
ABSORBENT & CLEAN UP W/SPARK PROOF TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:DONT' STORE > 120F. WHEN STORING LARGE
QUANTITIES TO PROTECT AGAINST FLAMMABLE LIQUIDS. USE STATIC LINES
WHEN MIXING & TRANSFERRING MATERIAL.
Other Precautions:DON'T ALLOW MATERIAL TO FREE FALL MORE THAN 5 INCHES.
FOR INDUSTRIAL USE ONLY. DON'T TAKE INTERNALLY. DON'T FLAME CUT,
WELD/BRAZE ON COATED METAL W/OUT A NIOSH/MSHA TC23C RESPIRATOR.
KEEP CONTAINER T IGHTLY CLOSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA TC23C CHEMICAL/MECHANICAL FILTER
SYSTEM TO REMOVE A COMBINATION OF PARTICLES, GAS & VAPORS.
Ventilation:USE ADEQUATE TO KEEP TLV'S & PEL'S < LEVEL & FLAMMABLE
LIMITS IN AIR. MECHANICAL(GENERAL)
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
FIRE PROCEDURES CONT'D: WATER MAY BE USED TO COOL CLOSED CONTAINERS TO
PREVENT PRESSURE BUILD UP DUE TO EXTREME HEAT. XYLENE: THE CRONIC
EFFECTS OF OVEREXPOSURE INCLUDE POSSIBLE LIVER & KIDNEY DAMAGE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:277F
Vapor Pres:5.1
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:94.5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACID, ALKALIES, OXIDIZERS.
Stability Condition to Avoid:EXTREME HEAT, OPEN FLAMES, SPARKS, HOT
SURFACES, ELECTRICAL & STATIC DISCHARGE.
Hazardous Decomposition Products:CO2, CO & CARBON SMOKE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN LANDFILL/INCINERATE IAW/FEDERAL,
STATE & LOCAL REGULATIONS. DON'T INCINERATE IN CLOSED CONTAINER.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:EUTECTRODE 670
CAGE:JO843
CAGE:72271
CAGE:JO843
============= Composition/Information on Ingredients =============
Ingred Name:IRON(CAS#7439-89-6)
CAS:7439-89-6
RTECS #:NO4565500
ACGIH TLV:5 MG/CUM(OSHA)
Ingred Name:CHROMIUM (SARA III)
CAS:7440-47-3
RTECS #:GB4200000
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
Ingred Name:CALCIUM CARBONATE (MARBLE) (LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9192
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
Effects of Overexposure:FUMES & GASES:DIZZINESS,NAUSEA,IRRITATION OF
NOSE & THROAT,SIDEROSIS;ARC RAY CAN HURT EYES & SKIN.
======================= First Aid Measures =======================
First Aid:REMOVE TO WELL-VENTILATED AREA.CALL FOR MEDICAL AID.EMPLOY
FIRST-AID TECHNIQUES RECOMMENDED BY THE AMERICAN RED CROSS.
===================== Fire Fighting Measures =====================
Extinguishing Media:NONE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:WELDING ARC & SPARKS,BRAZING FLAMES,AND
THERMAL SPRAYING CAN IGNITE COMBUSTIBLE & FLAMMABLES.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:READ & UNDERSTAND THE MFG'S
INSTRUCTIONS & PRECAUTIONARY LABEL ON THE PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH-APPROVED FUME RESPIRATOR
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:PROTECTIVE CLOTHING.
Supplemental Safety and Health
MSDS DATED 11-85. OTHER INGREDIENTS
INCLUDE:RUTILE,FELDSPAR,MANGANESE,FLUORSPAR,POTASSIUM
TITANATE,POTASSIUM HYDROXIDE,SODIUM SILICATE,SODIUM ALGINATE,COBALT
OXIDE,SILICA,SODIUM HYDROXIDE,ETC.
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:SOLID WIRE OR ROD.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:FUMES ARE COMPLEX OXIDES OF THE METALS
& FLUORIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HYDROFLUORIC ACID, 60% TECH
CAGE:3J729
CAGE:3J729
============= Composition/Information on Ingredients =============
Ingred Name:HYDROGEN FLUORIDE (SARA III)
CAS:7664-39-3
RTECS #:MW7875000
Fraction by Wt: 60%
Other REC Limits:NONE SPECIFIED
OSHA PEL:3 PPM/6 STEL (F)
ACGIH TLV:C 3 PPM (F); 9192
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:IHL-RAT LC50: 1276 PPM/1 HOUR
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HAZARDOUS LIQUID & VAPOR CAUSES SEVERE
BURNS WHICH MAY NOT BE IMMEDIATELY PAINFUL OR VISIBLE. VAPOR WILL
BURN EYES, NOSE & THROAT. VOLUNTARY INHALATION NORMALLY MINIMIZED
BY ITS SHARP ODOR. LIQUID CON TACT WITH SKIN CAUSES VERY PAINFUL &
MEDICALLY SERIOUS BURNS. LIQUID CONTACT WITH EYES CAN CAUSE
IMMEDIATE BLINDNESS.
Explanation of Carcinogenicity:HYDROFLUORIC ACID IS NOT LISTED BY IARC,
NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:INFLAMMATION OF THE NOSE, THROAT, UPPER
RESPIRATORY TRACT, EYES, SKIN AND MUCOUS MEMBRANES. VERY CORROSIVE
AND CAN CAUSE SEVERE BURNS AND DAMAGE. LONG TERM EXPOSURES SELDOM
OCCUR DUE TO THE CORROSIVEPROPERTIES OF THE ACID.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:VAPOR: MOVE TO FRESH AIR. IF BREATHING HAS STOPPED, GIVE
ARTIFICIAL RESPIRATION; IF DIFFICULT, GIVE OXYGEN. LIQUID: REMOVE
CONTAMINATED CLOTHING. FLUSH AFFECTED AREAS WITH PLENTY OF WATER &
COVER WITH25% MAGNESIUM SULFATE SOLUTION. EYES: IMMEDIATELY FLUSH
WITH PLENTY OF WATER FOR AT LEAST 30 MINUTES. INGESTION: IF
CONSCIOUS, GIVE WATER/MILK TO DRINK. DO NOT INDUCE VOMITING. GET
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:NONE
Extinguishing Media:USE WATER ON FIRES IN WHICH HYDROFLUORIC ACID IS
INVOLVED.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:NONCOMBUSTIBLE BUT DIFFICULT TO CONTAIN
AS IT CORRODES MOST SUBSTANCES EXCEPT LEAD, WAS, POLYETHYLENE AND
PLATINUM. MAY GENERATE HYDROGEN IN CONTACT W/ METALS.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILL: FLUSH WITH WATER AND NEUTRALIZE
WITH ALKALINE MATERIAL. SEWER NEUTRALIZED MATERIAL WITH EXCESS
WATER. LARGE SPILL: EVACUATE AND VENTILATE AREA. IF POSSIBLE, STOP
LEAK. DIKE TO RETAIN RUN OFF. NEUTRALIZE & PICK UP WITH ABSORBENT
MATERIAL.
Neutralizing Agent:SODA ASH, LIME OR OTHER SUITABLE ALKALINE MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT AGAINST PHYSICAL DAMAGE. STORE
IN WELL-VENTILATED AREA, SEPARATED FROM OTHER STORAGE. WEAR SPECIAL
PROTECTIVE CLOTHING WHEN HANDLING.
Other Precautions:FOR INDUSTRIAL USE ONLY. SEE CHEMICAL SAFETY DATA
SHEET SD-25 (MANUFACTURING CHEMISTS' ASSOCIATION, INC.)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL(TLV), USE NIOSH/MSHA APPROVED FULL FACEPIECE
CHEMICAL CARTRIDGE RESPIRATOR OR A SUPPLIED AIR FULL FACEPIECE
RESPIRATOR OR AIRLINED HOOD.
Ventilation:A SYSTEM OF LOCAL EXHAUST IS RECOMMENDED TO KEEP EMPLOYEE
EXPOSURES BELOW THE TLV.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
IMPERVIOUS BOOTS, APRON, AND COVERALLS.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID ANY EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO NOT BREATHE
VAPORS OR MISTS.
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:218F,103C
Vapor Pres:122
Vapor Density:1.97
Spec Gravity:1.208
pH:1.0
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID. STRONG IRRITATING ODOR.
Percent Volatiles by Volume:100
Corrosion Rate:RAPID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CORRODES MOST SUBSTANCES.
Hazardous Decomposition Products:WHEN HEATED TO DECOMPOSITION, EMITS
TOXIC HYDROGEN FLUORIDE FUMES. WILL REACT WITH WATER TO PRODUCE
HEAT & TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS. DISPOSE
IN A RCRA-APPROVED WASTE FACILITY OR SEWER THE NEUTRALIZED SLURRY
WITH EXCESS WATER IF LOCAL ORDINANCES ALLOW.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:EUTECROD 157-B
CAGE:72271
CAGE:72271
============= Composition/Information on Ingredients =============
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9293
Ingred Name:UREA
CAS:57-13-6
RTECS #:YR6250000
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMMONIUM CHLORIDE (SARA III)
CAS:12125-02-9
RTECS #:BP4550000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3/20 STEL
ACGIH TLV:10 MG/M3 FUME; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SILVER (SARA III)
CAS:7440-22-4
RTECS #:VW3500000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.01 MG/M3
ACGIH TLV:0.1 MG/M3; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:UNCLASSIFIED WELDING FUMES=5MG/M3 PEL
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SHORT TERM EXPOSURE TO WELDING FUMES,
GASES OR DUST MAY RESULT IN DISCOMFORT SUCH AS DIZZINESS, NAUSEA,
FEVER, DRYNESS AND/OR IRRITATION OF NOSE, THROAT AND EYES. SKIN
SENSITIVITY MAY ALSO BE NOTED. A CUTE EXPOSURE FROM SOME TOXIC
GASES MAYCAUSE PULMONARY EDEMA, ASPHYXIATION AND EXCESSIVE EXPOSURE
CAN BE FATAL.
Explanation of Carcinogenicity:PER MANUFACTURER, PRODUCT CONTAINS NO
INGREDIENTS CURRENTLY CLASSIFIED AS CARCINOGENIC BY NTP, IARC OR
OSHA.
Effects of Overexposure:EXPOSURE TO WELDING FUMES MAY RESULT IN
DISCOMFORT SUCH AS DIZZINESS, NAUSEA, FEVER, DRYNESS AND/OR
IRRITATION OF NOSE, THROAT AND EYES. SKIN SENSITIVITY MAY ALSO BE
NOTED. WATERY EYES, HEADACHE, BREA THING DIFFICULTY, FREQUENT
COUGHING AND/OR CHEST PAINS MAY OCCUR FROM ACUTE EXPOSURE. TOXIC
GASES CAN BE FATAL.
Medical Cond Aggravated by Exposure:SOME WORKERS MAY BE AFFECTED BY A
PRE-EXISTING CONDITION OR OTHER OCCUPATIONAL ILLNESS BECAUSE OF THE
WIDE VARIATION IN INDIVIDUAL SUSCEPTIBILITIES.
======================= First Aid Measures =======================
First Aid:IN CASE OF ELECTRICAL SHOCK, TURN OFF POWER PRIOR TO REMOVAL
FROM EXPOSURE AREA AND ADMINISTRATION OF FIRST AID. REMOVE FROM
EXPOSURE AREA AND CALL FOR MEDICAL AID. ADMINISTER OXYGEN IF
BREATHING IS D IFFICULT. IF NOT BREATHING, BEGIN ARTIFICIAL
RESPIRATION. IF NO DETECTABLE PULSE, BEGIN EXTERNAL HEART MASSAGE.
EMPLOY FIRST AID TECHNIQUES RECOMMENDED BY THE AMERICAN RED CROSS.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:NONFLAMMABLE. USE WATER FOG, CARBON DIOXIDE, FOAM,
OR DRY CHEMICAL AS REQUIRED BY SURROUNDING FIRE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP ANY GRINDING DUST OR WASTE RESIDUES
AND PLACE IN SUITABLE DOT APPROVED CONTAINERS AND DISPOSE OF IN
FULL COMPLIANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS. AVOID
INHALATION AND SKIN EXPOSU RE.
======================Handling and Storage ======================
CLOTHING WHEN CUTTING, GRINDING OR WELDING. DO NOT EXPOSE SKIN TO
RADIATION WHEN HOT CUTTING OR WELDING.
Other Precautions:PROVIDE PROTECTIVE SCREENS TO SHIELD OTHERS. WHEN
ELECTRODES AND FLUXES ARE CONSUMED, THE FUME AND GAS DECOMPOSITION
PRODUCTS GENERATED ARE DIFFERENT IN FORM FROM THE INGREDIENTS
LISTED. NEW COMPOUNDS NOT IN THE ELECTRODES MAY FORM.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE WELD FUME RESPIRATOR OR AIR SUPPLIED
RESPIRATOR WHEN CUTTING, GRINDING OR WELDING IN A CONFINED SPACE OR
WHERE LOCAL EXHAUST OR GENERAL VENTILATION DOES NOT KEEP EXPOSURE
BELOW RECOMMENDED LIMITS. USE ONLY NIOSH APPROVED RESPIRATORS.
Ventilation:USE ENOUGH VENTILATION WHEN CUTTING, GRINDING OR WELDING TO
KEEP THE DUST, FUMES & GASES FROM THE WORKERS BREATHING ZONE
Other Protective Equipment:FLAME RETARDANT CLOTHING WHEN CUTTING,
GRINDING OR WELDING. DO NOT EXPOSE SKIN TO RADIATION WHEN HOT
CUTTING OR WELDING.
Work Hygienic Practices:WASH THOROUGHLY BEFORE EATING OR SMOKING.
LAUNDER CONTAMINATIED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
WELDING AND HOT CUTTING FUMES & GASES CANNOT BE CLASSIFIED SIMPLY.
THEIR COMPOSITION AND QUANTITY ARE DEPENDENT ON THE METAL BEING
WELDED, THE PROCEDURES, PROCESSES AND THE TYPE OF WIRE OR
ELECTRODESUSED. OTHER INFLUENCING FACTORS ARE THEPRESENCE OF
CONTAMINANTS. CHLORINATED SOLVENTS MAY DECOMPOSE TO TOXIC GASES.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:SOLID
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:NOT GIVEN
Spec Gravity:NOT GIVEN
Evaporation Rate & Reference:NIL
Solubility in Water:NEGLIGIBLE
Appearance and Odor:SOLDER
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:WELDING AND CUTTING OPERATION MAY
INCLUDE OXIDES OF THE METALS, CHROMATES, FLUORIDES, COMPLEX
METALLICS, AND OZONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DISSOLVED OXYGEN CHEMETS,ULR CHEMETS AND VACU-VIALS,R-7501
Resp. Party Other MSDS Num.:1072-8
CAGE:7K791
Contract Num:SP0450-00-M-D223
CAGE:7K791
Contract Num:SP0450-00-M-D788
CAGE:7K791
Contract Num:SP0450-00-M-D976
CAGE:7K791
Contract Num:SP0450-99-M-C339
CAGE:7K791
Contract Num:SP0450-99-M-C503
CAGE:7K791
Contract Num:SP0450-01-M-D315
CAGE:71229
============= Composition/Information on Ingredients =============
Ingred Name:DIETHYLENE GLYCOL
CAS:111-46-6
RTECS #:ID5950000
= Wt:25.
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER (DEIONIZED)
CAS:7732-18-5
RTECS #:ZC0110000
> Wt:74.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
Ingred Name:OTHER COMPONENTS
< Wt:1.
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:NONE SPECIFIED BY
MANUFACTURER. ACUTE TOXICITY: IRRITATION. CHRONIC TOXICITY:
IRRITATION.
Explanation of Carcinogenicity:NONE OF THE INGREDIENTS IN THIS PRODUCT
IS CONSIDERED TO PRESENT A CARCINOGEN HAZARD.
Effects of Overexposure:IRRITATION.
Medical Cond Aggravated by Exposure:MAY CAUSE IRRITATION TO EYES, SKIN
AND MUCOUS MEMBRANES.
======================= First Aid Measures =======================
First Aid:INHALED: REMOVE INDIVIDUAL TO FRESH AIR. SKIN/EYES: FLUSH
WITH WATER FOR 15 MINUTES.INGESTION: SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER: DLA-HMIS:WEAR
PROTECTIVE CLOTHING AND NIOSH-APPROVED SELF-CONTAINED BREATHING
APPARATUS.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:TAKE UP WITH ABSORBENT MATERIAL. PLACE IN
SMALL CONTAINERS FFOR DISPOSAL. DISPOSE OF IN ACCORDANCE WITH ALL
FEDERAL, STATE AND LOCAL REGULATIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PRODUCT SHOULD BE STORED IN THE DARK
AND AT ROOM TEMPERATURE; HOWEVER, TEMPERATURES UP TO 120F OR EVEN
BELOW FREEZING WILL NOT NORMALLY EFFECT REAGENT PERFORMANCE.
Other Precautions:WASH THOROUGHLY AFTER HANDLING. KEEP OUT OF REACH OF
CHILDREN. DO NOT TAKE INTERNALLY. AVOID EYE AND SKIN CONTACT.
FRAGILE; LIQUID IN GLASS. HANDLE WITH CARE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. FRAGILE; LIQUID
IN GLASS. HANDLE WITH CARE.
Supplemental Safety and Health
IF THIS PRODUCT IS USED AS DIRECTED, THE USER WILL NOT COME IN CONTACT
WITH OR BE EXPOSED TO ANY OF ITS CHEMICAL COMPONENTS. AVOID EYE
CONTACT. CATALOG NUMBERS: R-7501, R-7501U, R-7501V, R-7511, R-75
18, R-7518U, R-7540, R-7540Q, R-7540N, R-7540U, R-7540V, R-7553,
K-7599; K-7599V.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:=150.C, 302.F
Melt/Freeze Pt:=-5.C, 23.F
Spec Gravity:1.03 (H20=1)
pH:11.5
Solubility in Water:MISCIBLE
Appearance and Odor:COLORLESS TO PALE YELLOW LIQUID - NO ODOR
================= Stability and Reactivity Data =================
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
=================== Toxicological Information===================
Toxicological Information:NONE SPECIFIED BY MANUFACTURER. IF THIS
PRODUCT IS USED AS DIRECTED, THE USER WILL NOT COME IN CONTACT WITH
OR BE EXPOSED TO ANY OF ITS CHEMICAL COMPONENTS.
===================== Ecological Information =====================
Ecological:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:NONE SPECIFIED BY MANUFACTURER.
===================== Regulatory Information =====================
SARA Title III Information:NONE SPECIFIED BY MANUFACTURER.
Federal Regulatory Information:NONE SPECIFIED BY MANUFACTURER.
State Regulatory Information:NONE SPECIFIED BY MANUFACTURER.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:10088 BELT DRESSING BULK
CAGE:CLING
CAGE:CLING
============= Composition/Information on Ingredients =============
Ingred Name:ASPHALT 3544
Fraction by Wt: 42%
Ingred Name:LEATHER OIL
Fraction by Wt: 25%
Ingred Name:STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 33%
Other REC Limits:350 MG/CUM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NAUSEA & DIZZINESS. NO
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: NAUSEA & DIZZINESS.
======================= First Aid Measures =======================
First Aid:INGESTION: DON'T INDUCE VOMITING. EYES: FLUSH W/PLENTY OF
WATER FOR AT LEAST 15 MINS. SKIN: REMOVE W/CLOTH OR PAPER & WASH
W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:145F
Extinguishing Media:FOAM, DRY CHEMICAL, OR CO2
Fire Fighting Procedures:DON'T USE SOLID STREAM OF WATER AS IT MAY
CAUSE FROTHING & SPREAD FIRE.
Unusual Fire/Explosion Hazard:HEAVY SOOT & CO MAY EMIT DURING FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION. COLLECT INTO
CONTAINERS & REMOVE BALANCE W/OIL ABSORBENT MATERIALS.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT W/SKIN.
Other Precautions:HANDLING AT ELEVATED TEMPERATURES MAY PRODUCE
EXCESSIVE VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRATORY EQUIPMENT WHEN >TLV OR WHEN
USING AT ELEVATED TEMPERATURES.
Ventilation:LOCAL EXHAUST
Work Hygienic Practices:REMOVE/WASH CLOTHING BEFORE REUSE. WASH
THOROUGHLY AFTER USING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:350F
Spec Gravity:0.895
Solubility in Water:SLIGHT
Appearance and Odor:BLACK LIQUID W/PERTROLEUM/ASPHALT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:OPEN FLAMES, STATIC ELECTRICITY, & ALL
SOURCES OF IGNITION
Hazardous Decomposition Products:CO & HEAVY SOOT
==================== Disposal Considerations ====================
Waste Disposal Methods:USE OIL DISPOSAL METHODS ACCORDING TO FEDERAL,
STATE. & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CITGARD 500 MOTOR OIL,SAE 15W-40
CAGE:7X110
CAGE:7X110
============= Composition/Information on Ingredients =============
Ingred Name:REFINED PETROLEUM OILS ALSO INCLUDING CAS NUMBERS
64741-88-4 AND 64741-89-5
CAS:64742-65-0
RTECS #:PY8038500
Fraction by Wt: 75-85% %
Other REC Limits:NONE SPECIFIED
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:DETERGENT INHIBITOR (CONTAINS ZINC DIALKYLDITHIOPHOSPHATE)
Fraction by Wt: 8 - 15%
Other REC Limits:NONE SPECIFIED
Ingred Name:VI IMPROVER
Fraction by Wt: < 10%
Other REC Limits:NONE SPECIFIED
Ingred Name:POUR DEPRESSANT
Fraction by Wt: <1% %
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:>5G/KG (ORAL LD50 RAT-PETROLEUM OIL)
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: LOW RISK AT AMBIENT
TEMPERATURES. MISTS OR FUMES MAY CAUSE RESPIRATORY IRRITATION OR
CHEMICAL PNEUMONITIS. DERMAL CONTACT: TRANSIENT, SLIGHT IRRITATION.
EYE CONTACT: PRACTICALLY NON -IRRITANT. INGESTION: LOW TOXICITY.
LESS THAN 1 OUNCE PASS THROUGH SYSTEM. LARGE QUANTITIES MAY CAUSE
GI DISCOMFORT.
Explanation of Carcinogenicity:PRODUCT CONTAINS NO MATERIALS CURRENTLY
CLASSIFIED BY NTP, IARC OR OSHA AS CARCINOGENS.
Effects of Overexposure:INHALATION OF MISTS MAY CAUSE DIZZINESS,
HEADACHE, NAUSEA. INGESTION OF LARGE QUANTITIES MAY CAUSE GI
DISCOMFORT, DIARRHEA, AND HEADACHE. INJECTION MAY CAUSE IRRITATION,
ERTHEMA, EDEMA. PROLONGED AND/ OR REPEATED DERMAL EXPOSURE MAY
CAUSE DRYING OF SKIN.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
NOTE TO PHYSICIAN: FOLLOWING INGESTION, AT A SAYBOLT VISCOSITY OF
530 AT 100F, THE RISK OF ASPIRATION IS REDUCED. FOR >1 OZ, EMESIS
OR LAVAGE MAY BE CONSIDERED.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE TO INCIDENTAL FUMES AND
PROVIDE RESPIRATORY SUPPORT IF NECESSARY. DERMAL: WASH WITH SOAP
AND WATER. EYES: FLUSH WITH LARGE VOLUMES OF WATER. INGESTION:
INDUCE VOMITING AND SEEK MEDICAL AID. INJECTION: SEEK MEDICAL AID.
NOTE TO PHYSICIAN: SUBCUTANEOUS INJECTION REQUIRES PROMPT SURGICAL
DEBRIDEMENT. IF NOT FAMILIAR WITH TECHNIQUE, SEEK SKILLED ADVICE.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:435F,224C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY. CONTAIN RUNOFF.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF HEAT OR IGNITION. PROVIDE
ADEQUATE VENTILATION. TAKE UP WITH NONCOMBUSTIBLE ABSORBENT SUCH AS
FULLERS EARTH OR SAND. PLACE INTO CONTAINERS FOR LATER DISPOSAL.
KEEP OUT OF WATERWAYS, SEWERS. REPORT TO APPROPRIATE AUTHORITIES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED AND AWAY
FROM HEAT AND FLAME. AVOID PROLONGED SKIN CONTACT WITH USED MOTOR
OILS.
Other Precautions:AFTER DRAINING OIL, WASH SKIN THOROUGHLY WITH SOAP
AND WATER. EMPTY CONTAINERS MAY CONTAIN PRODUCT RESIDUE WHICH COULD
INCLUDE FLAMMABLE OR EXPLOSIVE VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF HIGH VAPOR CONCENTRATION IS EXPECTED, USE
RESPIRATOR APPROVED FOR ORGANIC VAPORS.
Ventilation:IN CONFINED SPACES, MECHANICAL VENTILATION MAY BE REQUIRED
TO KEEP LEVELS OF CERTAIN COMPONENTS BELOW MANDATED STANDARDS
Other Protective Equipment:WEAR BODY COVERING WORK CLOTHES TO AVOID
PROLONGED OR REPEATED EXPOSURE. LAUNDER SOILED WORK CLOTHES BEFORE
REUSE.
Work Hygienic Practices:WASH SKIN THOROUGHLY WITH SOAP AND WATER AFTER
USE.
Supplemental Safety and Health
CONSULT APPROPRIATE FEDERAL, STATE AND LOCAL AUTHORITIES BEFORE
REUSING, RECONDITIONING, RECLAIMING, RECYCLING OR DISPOSING OF
EMPTY CONTAINERS AND/OR WASTE RESIDUES OF THIS PRODUCT.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:700F,371C
Vapor Pres:<0.001
Vapor Density:>1
Spec Gravity:0.89
Evaporation Rate & Reference:<1 (BU AC = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER FLUID, MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS, CAUSTICS.
Stability Condition to Avoid:EXTREMELY HIGH TEMPERATURES
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
TRACES OF OXIDES OF SULFUR, PHOSPHORUS, ZINC AND CALCIUM.
==================== Disposal Considerations ====================
Waste Disposal Methods:IT IS THE RESPONSIBILITY OF THE USER TO
DETERMINE IF THE MATERIAL IS A HAZARDOUS WASTE AT THE TIME OF
DISPOSAL. CHECK BEFORE DISPOSING TO BE SURE YOU ARE IN COMPLIANCE
WITH ALL APPLICABLE LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TT-P-102F TY III CL.3 #36521 700A99
Preparer's Name:ROBERT COMMISSO
CAGE:DO312
CAGE:58963
CAGE:DO312
============= Composition/Information on Ingredients =============
Ingred Name:ALIPHATIC HYDROCARBONS (STODDARD TYPE)(SARA III)(VAPOR
PRESSURE = 2.0 MMHG @ 68F)
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 10.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 10.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:MAGNESIUM SILICATE
CAS:14807-96-6
RTECS #:MW2700000
Fraction by Wt: 15.0%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:2 MG/M3
Ingred Name:MATERIAL VOC: 1.47 LB/GL (176 G/L)
RTECS #:9999999VO
Fraction by Wt: NA
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NA
ACGIH TLV:NA
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: DIRECT CONTACT MAY CAUSE
IRRITATION. PROLONGED CONTACT MAY CAUSE SKIN IRRITATION. INHAL:
HIGH VAPOR CONCENTRATIONS MAY LEAD TO LUNG CHANGES, NAUSEA,
VOMITING, COUGH, PULMONARY IRRITATION, CNS DE PRESSION. INGEST:
POSSIBLE GASTROINTESTINAL DISTURBANCES. ASPIRATION OF PRODUCT INTO
LUNGS MAY CAUSE PNEUMONITIS,*
Effects of Overexposure:EYES: POSSIBLE IRRITATION W/ DIRECT CONTACT.
SKIN: POSSIBLE IRRITATION &/OR DERMATITIS. MAY BE ABSORBED THROUGH
SKIN. *PULMONARY EDEMA & HEMORRAGE.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING
DISEASES IN OR HISTORY OF AILMENTS INVOLVING SKIN, CENTRAL NERVOUS
SYSTEM, LIVER AND KIDNEY.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/ LARGE AMOUNTS WATER 15 MINUTES.
SEEK MED AID. SKIN: WASH THOROUGHLY W/ SOAP & WATER. SEEK MED AID
IF IRRATION PERSISTS. INGEST: IMMEDIATELY SEEK MED AID. DO NOT
INDUCE VOMIT ING. DO NOT ATTEMPT TO GIVE ANYTHING BYMOUTH TO
UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:100F,38C
Autoignition Temp:Autoignition Temp Text:474F
Lower Limits:1.0
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:APPROVED GAS MASK REQUIRED FOR FIRE FIGHTING
PERSONNEL. WATER MAY BE INEFFECTIVE, MAY BE USED TO COOL
CONTAINERS. IF WATER USED, FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS & OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP LEAK IF NO RISK INVOLVED. REMOVE ALL
SOURCES OF IGNITION. STAY UPWIND. ABSORB WITH INERT MATERIAL. FLUSH
AREA W/ WATER. VENTILATE AREA FOR AT LEAST 24 HOURS OR UNTIL AREA
HAS BEEN DECLARED SAFE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED & UPRIGHT TO
PREVENT LEAKAGE. AVOID FLAMES, WELDING, OPEN LIGHTS, ETC. AVOID
BREATHING VAPOR & SPRAY MIST, SKIN & EYE CONTACT.
Other Precautions:MAINTAIN GOOD PERSONAL HYGIENE. DO NOT USE IN
CONFINED AREAS, TANK OR PIT WITHOUT ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW TLV (PEL), USE MSHA/NIOSH APPROVED UNITS. USE UNITS
PER CURRENT 29 CFR 1910.134 & FOLLOW MANUFACTURERS' INSTRUCTIONS &
WARNINGS. IF WITHIN O SHA PROTECTION FACTOR, AIR PURIFYING**
Ventilation:LOCAL AND MECHANICAL EXHAUST.
Other Protective Equipment:EYE BATH AND SAFETY SHOWER.
Work Hygienic Practices:MAINTAIN GOOD PERSON HYGIENE. DO NOT USE IN
CONFINED AREAS WITHOUT ADEQUATE VENTILATION.
Supplemental Safety and Health
**OV/FILTER UNITS OK FOR USE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:334F,168C
Vapor Density:>AIR
Spec Gravity:1.6 (WATER=1)
Viscosity:80-90 KU
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:ESSENTIALLY NIL
Appearance and Odor:VISCOUS LIQUID WITH TYPICAL PAINT ODOR, GRAY
Percent Volatiles by Volume:23.1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:FLAMES, SPARKS, SMOKING & HEAT
Hazardous Decomposition Products:CARBON MONOXIDE & CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:USE INERT ABSORBENT MATERIAL ON SPILLS. DISPOSE
IN ACCORDANCE WITH ALL FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ORGANIC PHOSPHOROUS REAGENT D R5416, Z416
Preparer's Name:R C JENTE
CAGE:21667
CAGE:21667
============= Composition/Information on Ingredients =============
Ingred Name:THORIUM(IV) NITRATE
CAS:13823-29-5
RTECS #:XO6825000
Fraction by Wt: 0.2%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: DIRECT CONTACT WITH EYES
MAY CAUSE SLIGHT IRRITATION. NO OTHER ILL EFFECTS WOULD BE EXPECTED
FROM CONTACT WITH THIS MATERIAL. CHRONIC: NONE KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MIN. SKIN: FLUSH WITH
WATER FOR AT LEAST 15 MIN. IF IRRITATION DEVELOPS, CONTACT PHYS.
INHAL: REMOVE TO FRESH AIR. SUPPORT BRTHG. (GIVE O2/ARTF RESP) .
ING EST: CALL MD IMMED .
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH EYES, SKIN AND
CLOTHING. WASH THOROUGHLY AFTER HANDLING.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NORMAL.
Other Protective Equipment:NONE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>212F,>100C
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS SOLUTION, NO ODOR.
Percent Volatiles by Volume:>99
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:UNKNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH WITH WATER. DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BE SERIES HEAVY DUTY REINHIBITOR 1
Resp. Party Other MSDS Num.:MSDSP145
Preparer's Name:JAMES L OTTOWITZ
CAGE:EO340
Contract Num:SP0450-99-M-NA63
CAGE:1JAE1
Contract Num:SP0450-00-M-SD51
CAGE:30255
CAGE:EO340
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA 313) (CERCLA)
CAS:107-21-1
RTECS #:KW2975000
Minumum % Wt:30.
Maxumum % Wt:40.
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:C STEL39PPM,A4,VAP96
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:DIETHYLENE GLYCOL
CAS:111-46-6
RTECS #:ID5950000
Minumum % Wt:0.
Maxumum % Wt:8.
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM MERCAPTOBENZOTHIAZOLE
CAS:2492-26-4
RTECS #:DL6825000
Minumum % Wt:1.
Maxumum % Wt:5.
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM BORATE/SODIUM TETRABORATE, DECAHYDRATE
CAS:1303-96-4
RTECS #:VZ2275000
Minumum % Wt:7.
Maxumum % Wt:13.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3
ACGIH TLV:5 MG/M3; 9495
Ingred Name:SODIUM SILICATE
CAS:1344-09-8
RTECS #:1002947SS
Minumum % Wt:3.
Maxumum % Wt:6.
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM TOLYTRIAZOLE/1,H-BENZOTRIAZOLE (4 OR 5)-METHYL
SODIUM SALT
CAS:64665-57-2
RTECS #:1003074BS
Minumum % Wt:1.
Maxumum % Wt:5.
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM HYDROXIDE (CERCLA)
CAS:1310-58-3
RTECS #:TT2100000
Minumum % Wt:7.
Maxumum % Wt:13.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:NON-HAZARDOUS INGREDIENTS
RTECS #:1000314NH
> Wt:1.
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Minumum % Wt:20.
Maxumum % Wt:50.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: EYE, SKIN, CNS,
RESPIRATORY & GI TRACTS. INGESTION MAY RESULT IN IMMEDIATE &
SEVERE BURNS TO LIPS, TONGUE, ORAL MUCOSA & ESOHPAGUS WITH GI
HEMORRHAGE & PERFORATION POSSIBLE; MAY BE FAT AL MAY CAUSE LIVER
INJURY. NO ADVERSE EFFECTS FROM SKIN ABSORPTION FROM AVAILABLE
INFORMATION. SKIN CONTACT MAY CAUSE IRRITATION &/OR CHEMICAL BURNS
RESULTING IN TISSUE DESTRUCTION. CONTACT WITH CAN C AUSE RAPID,
SEVERE IRRITATION &/OR CHEMICAL BURNS WHICH MAY RESULT IN TISSUE
DESTRUCTION & POSSIBLE BLINDNESS. CHRONIC: INHALATION OF MIST MAY
PRODUCE SIGNS OF CNS INVOLVEMENT. PROLONGED/REPEATED EXPO SURE MAY
CAUSE SKIN SENSITIZATION.
Explanation of Carcinogenicity:NONE SPECIFIED BY MANUFACTURER
Effects of Overexposure:INGESTED-DROOLING, DIFFICULTY IN
SWALLOWING/BREATHING/SPEAKING, CHEST PAIN, ABDOMINAL
PAIN/DISCOMFORT, NAUSEA, VOMITING, DIZZINESS, MALAISE, BLURRING OF
VISION, IRRITABILITY, LUMBAR PAIN, ELIGURIA, UR EMIA, CNS EFFECTS
INCLUDING IRREGULAR EYE MOVEMENT, CONVULSIONS, COMA.
INHALED-HOARSENESS, DIFFICULT BREATHING, RESPIRATORY DISTRESS,
NAUSEA, VOMITING, HEADACHE, DIZZINESS, IRREGULAR EYE MOVEMENTS. SK
IN-SEVERE IRRITATION, BURNS, EYES-SEVERE IRRITATION, CHEMICAL
BURNS.
Medical Cond Aggravated by Exposure:MAY AGGRAVATE EXISTING KIDNEY
DISEASE.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. SKIN: IMMEDIATELY
FLUSH WITH PLENTY OF WATER FOR 15 MINUTES WHILE REMOVING
CONTAMINATED CLOTHING. EYE: IMMEDIATELY FLUSH WITH WATER FOR 15
MINUTES, HOLDING E YELIDS OPEN. CALL PHYSICIAN. INHALED: MOVETO
FRESH AIR. PROVIDE CPR/OXYGEN. ORAL: DO NOT INDUCE VOMITING. IF
CONSCIOUS, DRINK A GLASS OF MILK/WATER. CALL A PHYSICIAN OR POISON
CONTROL CENTER IMMEDIATE LY.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:NONE TO BOILING
Autoignition Temp:Autoignition Temp Text:N/D
Lower Limits:N/D
Upper Limits:N/D
Extinguishing Media:WATER FOG, FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE POSITIVE PRESSURE SELF-CONTAINED BREATHING
APPARATUS WHEN ENTERING A CONFINED SPACE.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT
FOR HANDLING CORROSIVE MATERIALS. COLLECT FOR DISPOSAL USING AN
ABSORBENT MATERIAL, ( I.E. VERMICULITE) AND PLACE IN A CONTAINER
SUITABLE FOR CORROSIVE W ASTE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, VENTILATED AREA AWAY
FROM INCOMPATIBLE MATERIALS. KEEP OUT OF REACH OF CHILDREN. KEEP
CONTAINER CLOSED. DO NOT MIX DIRECTLY WITH OTHER MATERIALS. WEAR
PROPER PERSONAL PROTECTIVE CLOTHIN G WHEN HANDLING. KEEP AWAY FROM
PAPER, RAGS & OTHER COMBUSTIBLES.
Other Precautions:CORROSIVE! AVOID CONTACT WITH EYES AND SKIN. DO NOT
BREATH VAPORS. USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER
HANDLING. EMPTY CONTAINER RETAINS CORROSIVE RESIDUE AND MAY BE
DANGEROUS. DO NOT INGEST. FOR INDUSTRIAL USE ONLY. DO NOT STORE IN
OPEN OR UNLABELED CONTAINERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. IF TLV MAY BE EXCEEDED,A
NIOSH/MSHA APPROVED RESPIRATOR WITH AN ORGANIC VAPOR CARTRIDGE AND
A DUST/MIST PRE-FILTER OR A SUPPLIED AIR RESPIRATOR IS RECOMMENDED.
EQUIPMENT SELECT ION DEPENDS ON CONTAMINANT TYPE AND CONCENTRATION.
Ventilation:GENERAL VENTILATION SHOULD BE ADEQUATE FOR NORMAL USE. FOR
OPERATIONS WHERE THE MATERIAL IS HEATED OR MISTED AND THE TLV MAY
BE EXCEEDED,*(SEE BELOW)
BELOW)
Other Protective Equipment:PROTECTIVE CLOTHING SUCH AS APRON, COVERALL,
AND BOOTS IF NEEDED TO PREVENT SKIN CONTACT. SUITABLE WASHING AND
EYE FLUSHING FACILITIES SHOULD BE AVAILABLE IN THE IMMEDIATE WORK
AREA.
Work Hygienic Practices:CONTAMINATED CLOTHING SHOULD BE IMMEDIATELY
REMOVED AND LAUNDERED BEFORE RE-USE.
Supplemental Safety and Health
*FORCED VENTILATION SUCH AS LOCAL EXHAUST MAY BE NEEDED TO MAINTAIN
EXPOSURE LEVELS BELOW APPLICABLE LIMITS.**RECOMMENDED TO PREVENT
SKIN CONTACT.***THE ADDITIONAL USE OF A FACE SHIELD IS RECOMMENDED
IF SPLASHING IS POSSIBLE. DO NOT WEAR CONTACT LENSES.
================== Physical/Chemical Properties ==================
HCC:B2
Boiling Pt:=104.4C, 220.F
Melt/Freeze Pt:<-15.C, 5.F
Vapor Pres:N/D
Vapor Density:N/D
Spec Gravity:1.129 - 1.285
pH:14.0
Viscosity:N/D
Evaporation Rate & Reference:N/D
Solubility in Water:100%
Appearance and Odor:ORANGE-YELLOW
Percent Volatiles by Volume:N/D
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NORMALLY UNREACTIVE, HOWEVER, AVOID STRONG ACIDS, STRONG BASES, STRONG
OXIDIZING AGENTS, AND MATERIALS REACTIVE WITH HYDROXYL COMPOUNDS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:BURNING MAY PRODUCE CARBON MONOXIDE,
CARBON DIOXIDE.
=================== Toxicological Information===================
Toxicological Information:NONE SPECIFIED BY MANUFACTURER.
===================== Ecological Information =====================
Ecological:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MATERIAL IS A RCRA HAZARDOUS WASTE DUE TO
CORROSIVITY. DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:PROPER SHIPPING NAME: POTASSIUM HYDROXIDE
SOLUTION. HAZARD CLASS: 8. IDENTIFICATION NUMBER: UN1814. PACKING
GROUP: II. LABEL REQUIRED-CORROSIVE. PLACARDS REQUIRED-CORROSIVE.
===================== Regulatory Information =====================
SARA Title III Information:THIS PRODUCT CONTAINS THE FOLLOWING
CHEMICALS SUBJECT TO SARA TITLE III, SECTION 313 REPORTING:
ETHYLENE GLYCOL, CAS# 107-21-1, WT %=30-40.
Federal Regulatory Information:NONE SPECIFIED BY MANUFACTURER.
State Regulatory Information:CALIFORNIA PROPOSITION 65: THIS PRODUCT
CONTAINS TRACE LEVELS OF CHEMICALS WHICH THE STATE OF CALIFORNIA
HAS FOUND TO CAUSE CANCER AND/OR BIRTH DEFECTS OR OTHER
REPRODUCTIVE HARM.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DAZ-L FLOURESCENT SPRAY
CAGE:FO634
CAGE:91794
CAGE:FO634
============= Composition/Information on Ingredients =============
Ingred Name:HEXANE (N-HEXANE)
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: 10%
Other REC Limits:50 PPM
OSHA PEL:500 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:METHYLENE CHLORIDE(SARA III)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 25%
Other REC Limits:A2 CARCINOGEN
OSHA PEL:500 PPM/C,1000; Z2
ACGIH TLV:50 PPM, A2; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 5%
Other REC Limits:100 PPM
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: <25%
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9192
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: <25%
Other REC Limits:1000 PPM
OSHA PEL:1800 MG/CUM
ACGIH TLV:1000 PPM
Ingred Name:VM&P NAPHTHA (LIGROINE)
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 15%
Other REC Limits:STEL 400 PPM
OSHA PEL:300 PPM/400 STEL
ACGIH TLV:300 PPM; 9192
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: ANESTHETIC, IRRITATION OF
THE RESPIRATORY TRACT, NERVOUS SYSTEM DEPRESSION, HEADACHE,
DIZZINESS, STAGGERING GAIT, CONFUSION, UNCONSCIOUSNESS OR COMA.
SKIN/EYE: IRRITATION.
Explanation of Carcinogenicity:METHYLENE CHLORIDE IS CONSIDERED TO BE
AN ANIMAL CARCINOGEN.
Effects of Overexposure:INHALATION: IRRITATION OF THE RESPIRATORY
TRACT, NERVOUS SYSTEM DEPRESSION, HEADACHE, DIZZINESS, STAGGERING
GAIT, CONFUSION, UNCONSCIOUSNESS OR COMA. SKIN/EYES: IRRITATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE. GET FRESH AIR. EYES: FLUSH
W/LARGE QUANTITIES OF RUNNING WATER FOR AT LEAST 15 MINS. TAKE TO A
PHYSICIAN. SKIN: WIPE OFF W/TOWEL. REMOVE REMAINDER W/MINERAL
SPIRITS, TURPENTINE OR LACQUER THINNER, IN CASE OF A LACQUER. WASH
W/SOAP & WATER. REMOVE CONTAMINATED CLOTHING.
===================== Fire Fighting Measures =====================
Flash Point:-40F
Lower Limits:1.1%
Extinguishing Media:CO2, DRY CHEMICAL OR FOAM
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS
USED, FOG NOZZLES ARE PREFERABLE. WEAR SELF-CONTAINED BREATHING
APPARATUS.
Unusual Fire/Explosion Hazard:CANS WILL RUPTURE FROM INTERNAL PRESSURE
AT ABOUT 190F/DISCHARGE FLAMMABLE CONTENTS. WATER MAY BE USED TO
CLOSED CONTAINERS TO PRESSURE BUILD-UP/EXPLOSION.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITIONS, FLAMES, HOT
SURFACE, ELECTRICAL, STATE OR FRICTIONAL SPARKS. VENTILATE AREA.
REMOVE W/INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE >120F. DON'T SPRAY IN
EYES. DON'T PUNCTURE/INCINERATE CANS. DON'T STICK PIN, NAIL OR ANY
OTHER SHARP OBJECTS INTO OPENING ON TOP OF CAN.
Other Precautions:DON'T TAKE INTERNALLY. DON'T FLAME CUT, BRAZE OR WELD
W/O U.S. BUREAU OF MINES APPROVED RESPIRATOR OR APPROPRIATE
VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR CASUAL USE NONE REQUIRED, PROVIDED
VENTILATION IS AVAILABLE
Ventilation:PROVIDE MECHANICAL/LOCAL EXHAUST VENTILATION IN
VOLUME/PATTERN TO KEEP TLV/LEL
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:-42 TO 312F
Vapor Density:>AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Percent Volatiles by Volume:85%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:SOURCES OF IGNITIONS, FLAMES, HOT SURFACE,
ELECTRICAL, STATIC OR FRICTIONAL SPARKS. DON'T STORE >120F.
Hazardous Decomposition Products:HYDROGEN CHLORIDE, CO2, PHOSGENE,
TOXIC FUMES, WELDING OR FLAME CUTTING ON SURFACES COATED W/THIS
PRODUCT.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS. INCINERATE IN APPROVED FACILITY. DON'T
INCINERATE CLOSED CONTAINERS. FLAMMABLE LIQUID.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:MERCURIC NITRATE 0.5N
CAGE:66378
CAGE:66378
============= Composition/Information on Ingredients =============
Ingred Name:MERCURIC NITRATE (SARA 313)
CAS:10045-94-0
RTECS #:OW8225000
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.1 MG (HG)/M3; Z-2
ACGIH TLV:S,0.025 MG(HG)/M3;95
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:WATER (NOT GIVEN IN MFR MSDS BUT IS A MIL-SPEC REQUIREMENT)
CAS:7732-18-5
RTECS #:ZC0110000
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS 285 MG/KG (HGNO3)
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY CAUSE IRRITATION OF SKIN,
EYES, AND GI TRACT. CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NO MATERIAL >1% IS LISTED AS A
CARCINOGEN BY NTP, IARC OR OSHA.
Effects of Overexposure:EYES: REDNESS, TEARING. SKIN: REDNESS, RASH.
INGESTION: NAUSEA, VOMITING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION-REMOVE TO FRESH AIR. EYES-FLUSH WITH WATER FOR 15
MINUTES. SEE DOCTOR. SKIN-WASH WITH SOAP AND WATER. REMOVE
CONTAMINATED CLOTHING. INGESTION-DO NOT INDUCE VOMITING. GET
IMMEDIATE MEDICAL H ELP.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS IN
POSITIVE-PRESSURE MODE AND FULL PROTECTIVE GEAR WHEN FIGHTING FIRES
TO WHICH CHEMICALS ARE EXPOSED.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPLLED MATERIAL. ABSORB WITH INERT
MATERIAL. SCOOP UP AND PLACE IN A CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
AVOID CONTACT WITH SKIN OR EYES.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. USE NIOSH/MSHA APPROVED
RESPIRATOR WITH MERCURY FILTER IF PEL/TLV EXCEEDED.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER. IMPERVIOUS
APRON AND FOOTWEAR.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:T4
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIQIUD.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACETYLENE, ETHANOL, SULFUR, PHOSPHOROUS ANHYDRIDE, HYPOPHOSPHORIC ACID.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:OXIDES OF NITROGEN, MERCURY.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:THIS PRODUCT MAY BE ELIGIBLE AS A LIMITED
QUANTITY IAW DOT 173.155(B) & IMDG 18.3; GROSS PACKAGE AS SUPPLIED,
EXCEEDS LIMITED QUANTITY GROSS LIMIT. IF LIMITED QUANTITY APPLIES,
LABEL IAW IMDG 18.7.1, MARINE POLLUTANT LABELS IS NOT REQUIRED;
USE DANGEROUS GOODS IN LIMITED QUANTITY (SEE IMDG 18.7.1.2).
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:6010-0927, 21 HEWLETT PACKARD-ALL COLORS (S
Preparer's Name:MIKE A. TRAQUINA
CAGE:33451
CAGE:33451
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL SPIRITS. VP:2 @ 68F
CAS:64742-88-7
OSHA PEL:500 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:VM&P NAPHTHA. VP:15 @ 100F
CAS:64742-89-8
OSHA PEL:300 PPM; 400 STEL
ACGIH TLV:300 PPM
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE. VP:5.1 @ 68F
CAS:1330-20-7
RTECS #:ZE2100000
OSHA PEL:100 PPM; 150 STEL
ACGIH TLV:100 PPM; 150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE (SARA III). VP:186 @ 68F
CAS:67-64-1
RTECS #:AL3150000
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPANE. VP:5689 @ 68F
CAS:74-98-6
RTECS #:TX2275000
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:PROPANE, 2-METHYL-; (ISOBUTANE). VP:1551 @ 68F
CAS:75-28-5
RTECS #:TZ4300000
Ingred Name:BUTANE; (NORMAL BUTANE). VP:848 @ 68F
CAS:106-97-8
RTECS #:EJ4200000
OSHA PEL:800 PPM
ACGIH TLV:800 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC: INHAL:ANESTHETIC.
IRRITATION OF THE RESPIRATORY TRACT OR NERVOUS SYSTEM DEPRESSION,
CHARACTERIZED BY HEADACHE, DIZZINESS, NAUSEA OR POSSIBLE
UNCONSCIOUSNESS. SKIN/EYE:PRIMARY IRRITATION . PROLONGED OR
REPEATED CONTACT TO SKINMAY CAUSE DERMATITIS. EXERCISE DUE CARE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:INHAL:MAY CAUSE DIZZINESS OR NAUSEA. SKIN: MAY
CAUSE IRRITATION OR BURNING SENSATION. EYE:PRIMARY
IRRITATION.TOLUENE CAS 108-88-3 APPEARS ON THE NAVY LISTING OF
OCCUP REPRO HAZ. SEEK CONSULTATION FROM APPROP HLTH PROFESSIONALS
CONCERN LATEST HAZ LIST INFO AND SAFE HANDLING AND EXPOS
RECOMMENDATIONS .
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOSURE & RESTORE BREATHING. SEEK MEDICAL
ATTENTION. SKIN:WASH AFFECTED AREA, REMOVE CONTAMINATED CLOTHING,
SEE MD IF ANY IRRITATION PERSISTS. EYE:FLUSH IMMEDIATELY W/WATER
FOR AT L EAST 15 MINS & TAKE TO A MD. INGEST:CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-18F,-28C
Lower Limits:0.1%
Upper Limits:12.8%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL & WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER SPRAY MAY BE INEFT, BUT MAY BE USED TO COOL CONTRS EXPOSED
TO HEAT/FIRE TO PVNT PRESS BUILD-UP.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE DUE TO
BUILD UP OF PRESSURE FROM EXTREME HEAT OR FIRE. AEROSOL SPRAY IS
EXTREMELY FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION: FLAMES,
SPARKS, STATIC ELECTRICITY & ELECTRICAL. VENTILATE AREA & SOAK UP
W/INERT ABSORBENT USING NON-SPARKING TYPE TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. DO NOT STORE
OR USE NEAR HEAT, SPARKS OR FLAME.
Other Precautions:DO NOT GET IN EYES. DO NOT BREATHE VAPOR. AVOID SKIN
CONTACT. DO NOT TAKE INTERNALLY. SMOKING WHILE USING THIS PRODUCT
MUST BE STRICTLY PROHIBITED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:OUTDOORS: WE RECOMMEND A NIOSH/MSHA APPROVED
PARTICULATE FILTER TO REMOVE ANY AIRBORNE OVERSPRAY. IN RESTRICTED
AREAS W/ POOR VENTILATION & CLOSE TO TLV, A NIOSH/MSHA APPROVED
RESPIRATOR W/ORGANIC VAP OR CARTRIDGE IS RECOMMENDED.
Ventilation:ALL APPLICATN AREAS SHOULD BE ADEQUATELY VENTILATED IN
ORDER TO KEEP INGREDS IN INGRED SECTION BELOW THEIR EXPOS LIMITS.
Other Protective Equipment:IMPERVIOUS APRON IS RECOMMENDED TO PREVENT
SKIN CONTACT.
Work Hygienic Practices:REMOVE & WASH CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
MFRS TRADE NAME/PART NO: COCOA BLACK PANEL
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:-10F,-23C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:0.8 (H2O=1)
Evaporation Rate & Reference:FASTER THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OPAQUE LIQUID; SOLVENT BASED ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:CO, CO2, HCL & POSSIBLY TRACES OF
PHOSGENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ACTIVATED CARBON
Preparer's Name:D.E. KUBELDIS
CAGE:86368
CAGE:86368
============= Composition/Information on Ingredients =============
Ingred Name:GRAPHITE, SYNTHETIC
CAS:7440-44-0
RTECS #:FF5250100
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9394
===================== Hazards Identification =====================
LD50 LC50 Mixture:ACUTE ORAL LD50 (RAT) >10 G/KG
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION- THE ACUTE INHALATION LC50
(RAT) IS >64.4 MG/L (NOMINAL CONCENTRATION) FOR ACTIVATED CARBON.
SKIN- THE PRODUCT IS NOT A PRIMARY SKIN IRRITANT. EYES- THE
PHYSICAL NATURE OF THE PRODUCT MAY P RODUCE EYE IRRITATION.
CHRONIC: THE EFFECTS OF LONG-TERM, LOW-LEVEL EXPOSURES TO THIS
PRODUCT HAVE NOT BEEN DETERMINED.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES- FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.
SKIN- WASH WITH SOAP AND WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:IF INVOLVED IN FIRE, FLOOD WITH PLENTY OF WATER.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:CONTACT WITH STRONG OXIDIZERS SUCH AS
OZONE, LIQUID OXYGEN, CHLORINE, PERMANGANATE, ETC. MAY RESULT IN
FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP UNUSED CARBON AND DISCARD IN REFUSE
CONTAINER OR REPACKAGE.
======================Handling and Storage ======================
Handling and Storage Precautions:WET ACTIVATED CARBON REMOVES OXYGEN
FROM AIR CAUSING A SEVERE HAZARD TO WORKERS INSIDE CARBON VESSELS
AND ENCLOSED OR CONFINED SPACES.
Other Precautions:WASH THOROUGHLY AFTER HANDLING. EXERCISE CAUTION IN
THE STORAGE AND HANDLING OF ALL CHEMICAL SUBSTANCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH-APPROVED PARTICULATE FILTER RESPIRATOR
IS RECOMMENDED IF EXCESSIVE DUST IS GENERATED.
Ventilation:LOCAL EXHAUST AND MECHANICAL VENTILATION RECOMMENDED.
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING THIS
MATERIAL.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:2.3 G/CC
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK PARTICULATE SOLID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS SUCH AS OZONE, LIQUID OXYGEN, CHLORINE, PERMANGANATE,
ETC.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CARBON MONOXIDE MAY BE GENERATED IN
THE EVENT OF FIRE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF UNUSED CARBON IN REFUSE CONTAINER.
DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HOUSEHOLD OIL
CAGE:46935
CAGE:46935
============= Composition/Information on Ingredients =============
Ingred Name:HYDROCARBONS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: MILD IRRIT. SKIN:
PRACTICALLY NON-TOXIC BY SKIN ABSORPTION. MILD IRRIT WITH
PROLONGED/RPTD CONTACT. INHAL: NONE EXPECTED. INGEST: PRACTICALLY
NON-TOXIC. PRESSURIZED INJECTION OF PRODUCT UN DER THE SKIN CAN
LEAD TO SERIOUSLY INFLAMMED TISSUE. IF LEFT UNTREATED INJURY CAN BE
GANGRENOUS.(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: CONTINUOUS SKIN CONTACT WITH USED
MOTOR OILS HAS CAUSED SKIN CANCER IN LAB ANIMALS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/RUNNING H2O FOR @ LST 15 MIN. IF IRRIT DEVELOPS,
SEK MED ATTN. FOR INJECTION INJURIES, IMMED MED TREATMENT IS
REQUIRED. SKIN:WASH W/SOAP & H2O. IF IRRIT DEVELOPS, SEEK MED ATTN.
FOR INJECT ION INJURIES, IMMED MED TREATMENT IS REQUIRED.
INHAL:REMOVE FROM EXPOS. IF ILLNESS/ADVERSE SYMPS DEVELOP, SEEK MED
ATTN. INGEST:GIVE 2 GLASSES OF H2O & INDUCE VOMIT. IF
ILLNESS/ADVERSE (SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>280F,>138C
Extinguishing Media:DRY CHEMICAL, FOAM OR CO2.
Fire Fighting Procedures:EVAC AREA OF ALL UNNEC PERSONNEL. SHUT OFF
SOURCE, IF POSS. USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP. H2O
FOG MAY BE USED TO COOL EXPOS CNTNR/EQUIP.
Unusual Fire/Explosion Hazard:CARBON OXIDES AND VARIOUS HYDROCARBONS
FORMED WHEN BURNED.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROT EQUIP &/OR GARMENTS IF EXPOSURE
CNDTNS WARRANT. SHUT OFF SOURCE, IF POSSIBLE & CONTAIN SPILL.
PROTECT FROM IGNITION. KEEP OUT OF WATER SOURCES & SEWERS. ABSORB
IN DRY, INERT MATERIAL (SAND, CLAY, SAWDUST, ETC.) TRANSFER TO
DISP DRUMS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID INHALATION OF MIST AND EYE
CONTACT. AVOID REPEATED CONTACT WITH SKIN. WEAR PROTECTIVE
EQUIPMENT AND/OR GARMENTS IF CONDITIONS WARRANT.
Other Precautions:STORE AWAY FROM IGNITION SOURCES. PROVIDE MEANS OF
CONTROLLING LEAKS AND SPILLS. KEEP CONTAINERS CLOSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT GENERALLY REQUIRED.FOR CONCENTRATIOS
EXCEEDING THE RECOMMENDED EXPOSURE LEVEL, USE NIOSH/MSHA APPROVED
AIR PURIFYING RESPIRATOR.
Ventilation:USE ADEQUATE VENTILATION TO CONTROL EXPOSURE BELOW
RECOMMENDED LEVELS.
Other Protective Equipment:USE PROTECTIVE GARMENTS TO PREVENT EXCESSIVE
SKIN CNTCT. WHERE SPECIAL/UNUSUAL USES/CONDITIONS EXIST, EXPERT
(SUPP DATA)
Work Hygienic Practices:WASH HANDS AFTER HANDLING. LAUNDER CONTAMINATED
CLOTHING BEFORE REUSE.
Supplemental Safety and Health
SPEC GRAV: 0.86-0.94 (H2O=1). FIRST AID PROC: SYMPTOMS DEVELOP, SEEK
MEDICAL ATTENTION. PHYSICIANS MAY CALL (918) 661-4845. OTHER PROT
EQUIP: ASSISTANCE OF INDUST HYGIENIST SUGGESTED.
================== Physical/Chemical Properties ==================
HCC:V6
Vapor Pres:< 1 @ 20C
Vapor Density:> 5
Spec Gravity:SUPP DATA
Evaporation Rate & Reference:NEGLIGIBLE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS TO DARK LIQUID WITH MILD ODOR.
Percent Volatiles by Volume:NEGLIG
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXYGEN AND STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON OXIDES AND VARIOUS HYDROCARBONS
FORMED WHEN BURNED.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR OTHERWISE MANAGE AT A PERMITTED
WASTE MANAGEMENT FACILITY. DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:GASKET
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:31361
CAGE:31361
============= Composition/Information on Ingredients =============
Ingred Name:THE GASKET MATERIAL DESCRIBED BY THE MSDS MAY CONTAIN ONE
OR MORE OF THE FOLLOWING INGREDIENTS.
RTECS #:9999999ZZ
Ingred Name:NITRILE
Other REC Limits:NONE SPECIFIED
Ingred Name:CORK
Other REC Limits:NONE SPECIFIED
Ingred Name:RUBBER
Other REC Limits:NONE SPECIFIED
Ingred Name:TEFLON
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT IS AN ARTICLE. MSDS COVERS
HAZARDOUS DUST PRODUCED WHEN ARTICLE IS CUT, SANDED, GROUND, SAWED,
ETC. INHALATION OF INERT DUST IS THE CHRONIC AND ACUTE HAZARD.
Explanation of Carcinogenicity:THE PRODUCT CONTAINS NO INGREDIENT THAT
IS LISTED BY IARC, NTP OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYES: MECHANICAL IRRITATION BY DUST. SKIN:
POSSIBLE MECHANICAL IRRITATION BY DUST. INHALATION OF DUST:
TRANSIENT MECHANICAL IRRITATION OF RESPIRATORY TRACT AND PULMONARY
DAMAGE BY CHRONIC OVEREXPOSURE TO THE DUST. INGESTION: NON-TOXIC.
NO KNOWN SYMPTOMS.
Medical Cond Aggravated by Exposure:NONE GIVEN BY MANUMACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER 15 MIN, HOLD LIDS OPEN. SKIN: WASH
WITH SOAP AND WATER. INHALATION: REMOVE TO FRESH AIR. RESTORE
BREATHING IF NECESSARY. INGESTION: DO NOT INDUCE VOMITING. GIVE 2
LARGE GLASSES OF MILK OR WATER. OBSERVE FOR SYMPTOMS AND GET
MEDICAL CARE IF NEEDED. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. IF
IRRITATION PERSISTS OR IS SEVERE, GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP OR VACUUM. USE CARE TO KEEP
RESPIRABLE DUST TO A MINIMUM AND USE RESPIRATOR IF NECESSARY.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP SEALED AND DRY.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR WILL NOT NORMALLY BE NECESSARY. USE
NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR OR RESPIRATOR FOR
NUISANCE DUST IF EXPOSURE IS ABOVE THE TLV/PEL. SEE 29 CFR 1910.134
FOR REGULATIONS PERTAIN ING TO RESPIRATOR USE.
Ventilation:VENTILATION IS REQUIRED ONLY WHEN ENGAGING IN A DUST
PRODUCING OPERATION WHERE PEL/TLV OF NUISANCE DUST IS EXCEEDED.
Other Protective Equipment:INDUSTRIAL TYPE CLOTHING AS REQUIRED TO
PREVENT PROLONGED OR REPEATED SKIN CONTACT.
Work Hygienic Practices:USE GOOD INDUSTRIAL HYGIENE PRACTICE. AVOID
UNNECESSARY CONTACT. WASH THOROUGHLY BEFORE EATING OR DRINKING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:GASKET APPEARANCE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
IT MAY SENSITIZE ACUTE ALLERGIC REACTION
Stability Condition to Avoid:IT MAY SENSITIZE ACUTE ALLERGIC REACTION
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS. IF REGULATIONS PERMIT WASTE MATERIAL MAY
BE TREATED AS ORDINARY REFUSE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ARTISTA II POWDER PAINT, 59-1600-36-ORANGE
CAGE:85419
CAGE:85419
============= Composition/Information on Ingredients =============
Ingred Name:CALCIUM CARBONATE; (MARBLE), (LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:ALUMINUM SILICATE
CAS:1332-58-7
RTECS #:GF1670500
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC: NONE KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.
CONTACT PHYSICIAN. SKIN: WASH WITH SOAP AND WATER. INGESTION: DO
NOT INDUCE VOMITING. CONTACT PHYSICIAN OR POISON CONTROL CENTER.
INHALATION: REMOVE PERSON TO FRESH AIR.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, CARBON DIOXIDE, FOAM OR HALON 1211
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER FREE PRODUCT. KEEP PRODUCT OUT OF
SEWERS AND WATERCOURSES BY DIKING OR IMPOUNDING. ADVISE AUTHORITIES
IF PRODUCT ENTERS SEWERS AND WATERCOURSES. ASSURE CONFORMITY WITH
APPLICABLE GOVERNMENTAL REGULATIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:GENERAL VENTILATION SUFFICIENT TO KEEP AIRBORNE
CONCENTRATION BELOW CURRENT EXPOSURE LIMITS .
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:CLEAN, SAFE WORK PRACTICES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Solubility in Water:COMPLETE
Appearance and Odor:VARIOUS COLORS-NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:USA 316L
CAGE:JO533
CAGE:0AZS7
CAGE:JO533
============= Composition/Information on Ingredients =============
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:NICKEL (SARA 313) (CERCLA) (MFR'S CAS #7440-02-2)
CAS:7440-02-0
RTECS #:QR5950000
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
OSHA PEL:10 PPM
ACGIH TLV:10 PPM
Ingred Name:MANGANESE (SARA 313)
CAS:7439-96-5
RTECS #:OO9275000
OSHA PEL:5 MG/M3 DUST, C
ACGIH TLV:5 MG/M3 DUST
Ingred Name:CHROMIUM (SARA 313) (CERCLA)
CAS:7440-47-3
RTECS #:GB4200000
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:NIOBIUM; (COLUMBIUM)
CAS:7440-03-1
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CALCIUM FLUORIDE
CAS:7789-75-5
RTECS #:EW1760000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM SILICATE
CAS:1344-09-8
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CLAY (KAOLIN); (ALUMINUM SILICATES)
CAS:1332-58-7
RTECS #:GF1670500
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST
Ingred Name:POTASSIUM SILICATES
CAS:1312-76-1
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CRYOLITE
CAS:15096-52-3
RTECS #:WA9625000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ZIRCONIUM SILICATES
CAS:7440-42-6
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:COPPER (SARA 313) (CERCLA)
CAS:7440-50-8
RTECS #:GL5325000
OSHA PEL:0.1MG/M3 FUME;1 DUST
ACGIH TLV:0.2 MG/M3 FUME
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (QUARTZ)
CAS:14808-60-7
RTECS #:VV7330000
OSHA PEL:N/K
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:SUPDAT: BE REACHED BEFORE LIM OF 5 MG/M3 FOR GEN WELDING
FUMES IS REACHED. WATCH CR(VI) LEVEL. GASEOUS RXN PRODS(ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:MAY INCL CO & CO*2. OZONE & NITROGEN OXIDES MAY BE
FORMED BY RADIA FROM ARC. CONTACT NEHC FOR MORE INFO .
RTECS #:9999999ZZ
Ingred Name:EXPLAN OF CARCIN:CRYSTALLINE-QUARTZ:IARC MONO, V 68,
1997:GRP 1. NTP 7TH ANNUAL RPT ON CARCINS, 1994:ANTIC TO BE CARCIN.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP: IN LUNG) & IS BELIEVED TO AFFECT PULM
FUNC. REPETITIVE EXPOS TO FLUORIDE FUMES &/OR GASES MAY (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21: CAUSE EXCESS CALCIFICATION OF BONES & LIGAMENTS OF
RIBS, PELVIS & SPINAL COLUMN. CHROMIUM(VI) CMPDS MAY (ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22:CAUSE ULCERATION & PERFORATION OF NASAL SEPTUM &
LIVER & KIDNEY DMG. REPETITIVE OVEREXP TO NICKEL OXIDES (ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23: MAY LEAD TO LUNG FIBROSIS OR PNEUMOCONIOSIS. ARC
RAYS CAN INJURE EYES & BURN SKIN. ELEC SHOCK CAN KILL.
RTECS #:9999999ZZ
Ingred Name:EYE PROT:& FULL LNGTH FSHLD W/FILTER LENS SHADE
#12-14/DARKER. SHIELD OTHERS BY PROVIDING SCREENS & FLASH GOGGS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE OVEREXP TO WELDING FUMES MAY
RSLT IN DISCOMFORT SUCH AS DIZZ, NAUS OR DRYNESS/IRRIT OF NOSE,
THROAT/EYES. INHAL OF EXTREMELY HIGH LEVELS OF FLUORIDES MAY CAUSE
ABDOM PAIN, DIARR, MUSC WEAK & CON VLS. CONTINUED INHAL COULD CAUSE
UNCON & DEATH. CHROMIUM (VI) CMPDS PRESENT IN FUME MAY CAUSE SEV
IRRIT(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NICKEL: IARC MONO, VOL 49, PG 257,
1990:GRP 2B. NTP 7TH ANNUAL RPT ON CARCINS, 1994:ANTIC TO BE
CARCIN. SILICA, (ING 20)
Effects of Overexposure:HLTH HAZ: OF BRONCH TUBES & LUNGS. INGEST OF
CHROMIUM (VI) SALTS MAY CAUSE INJURY/DEATH. CHROMIUM(VI) CMPDS MAY
BURN EYES. CHROMIUM CMPDS MAY CAUSE ALLERGIC RXNS. NICKEL OXIDES IN
FUME MAY CAUSE TIGHT NESS AROUND CHEST, FEVER & ALLERGIC RXNS.
CHRONIC OVEREXP TO WELDING FUMES CAN LEAD TO SIDEROSIS (IRON
DEPOSITS (ING 21)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMED . EYES: IMMED FLUSH W/POTABLE WATER FOR
A MINIMUM OF 15 MINUTES, SEEK ASSISTANCE FROM MD . SKIN: FLUSH
W/COPIOUS AMTS OF WATER. CALL MD . CALL FOR MED ASSISTANC E. USE
FIRST AID PROCEDURERS RECOM BY AMERICAN RED CROSS. IF BREATHING IS
DFCLT, GIVE OXYGEN. IF NOT BREATHING USE CPR. CONSULT MD IF
IRRITATION OF EYES & SKIN OR FLASH BURNS DEVELOP AFTER EXPOSURE.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NON-FLAMMABLE: WELDING ARC AND SPARKS CAN
IGNITE COMBUSTIBLES. SEE Z-49.1 SAFETY IN WELDING & CUTTING,
PUBLISHED BY AWS, 550 NW LEJEUNE RD, MIAMI, FL 33126.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:READ & UNDERSTAND MFR'S INSTRUCTIONS &
PREC LABEL ON PROD. ADVISE WELDERS TO KEEP THEIR HEAD OUT OF FUMES.
SEE ANSI Z49.1 & 29 CFR 1910 FOR MORE INFO.
Other Precautions:ONE METHOD OF DETERMINING COMPOSITION & QTY OF FUMES
& GASES TO WHICH WORKERS ARE EXPOSED IS TO TAKE AIR SAMPLE FROM
INSIDE WELDER'S HELMET WHILE WORN OR IN WORKER'S BREATHING ZONE.
SEE ANSI/AWS F1.1 AVAIL FROM AMERICAN WELDING SOCIETY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRABLE FUME RESPIRATOR OR
AIR SUPPLIED RESPIRATOR WHEN WELDING IN CONFINED SPACE OR GENERAL
WORK AREA WHERE LOCAL EXHAUST AND/OR VENTILATION DOES NOT KEEP
EXPOSURE BELOW THE THR ESHOLD LIMIT VALUE.
Ventilation:USE PLENTY OF VENT &/OR LOC EXHST AT ARC TO KEEP FUMES &
GASES BELOW TLV W/IN WORKER'S BRTHG ZONE & GEN WORK AREA.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . ARM
PROTECTORS, APRON, HATS, SHOULDER PROT & DARK SUBSTANTIAL CLTHG.
Work Hygienic Practices:TRAIN WELDER NOT TO ALLOW ELEC LIVE PARTS TO
GROUND.
Supplemental Safety and Health
HAZ DECOMP PRODS: WELDED, PROCS FOLLOWED & ELECTRODES USED. REASONABLE
EXPECTED FUME CONSTITUENTS OF PROD WOULD INCL: COMPLEX OXIDES OF
ALUMINUM, IRON, MANGANESE, SILICON, TITANIUM, CHROMIUM, NICKEL,
CALCIUM, COLUMBIAN, MOLYBDENUM & COPPER. FLUORIDES WILL ASLO BE
PRESENT. FUME LIM FOR (CR(VI)(0.05 MG/M3) MAY (ING 18)
================== Physical/Chemical Properties ==================
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WELDING FUMES & GASES CANNOT BE
CLASSIFIED SIMPLY. COMPOSITION & QTY OF FUMES & GASES DEPEND ON
METAL BEING (SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER
OR LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER APPROVED BY
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: FRESH KOTE HOUSE PAINT, 409875
Cage: HO637
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 85519
Box: 600
Cage: HO637
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:INHALATION:IRRITATION OF RESPIRATORY TRACT.
PROLONGED INHALATION MAY LEAD TO MUCOUS MEMBRANE IRRITATION, DROWSINESS,
AND/OR LIGHT-HEADEDNESS, HEADACHE, NAUSEA. SKIN:IRRITATION. PROLONGED OR REPE
ATED CONTACT CAN CAUSE DERMATITIS. EYE:IRRITATION. PROLONGED OR REPEATED
CONTACT CAN CAUSE BLURRED (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ:VISION, CORNEAL INJURY.
INGESTION:AMOUNTS INGESTED INCIDENTAL TO CONSUMER & INDUST HANDLING ARE
NOT LIKELY TO CAUSE INJURY; HOWEVER, INGESTION OF LARGER AMOUNTS COULD CAUSE
SERIOUS INJURY.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL:REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
HAVE TRAINED PERSON GIVE OXYG IF NEC. GET EMER MED ATTN. SKIN:WASH OFF
QUICKLY W/PLENTY OF WATER, THEN SOAP & WATER; REMOVE CONTAMD CLTHG. WASH
CONTAMD CLTHG BEFORE REUSE. EYE:FLUSH IMMED W/LG AMTS OF WATER, ESPECIALLY
UNDER LIDS, FOR @ LST 15 MINS. OBTAIN EMER MED TREATMENT. INGEST:OBTAIN
MEDICAL TREATMENT IMMEDIATELY.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: COLLECT IN CONTAINER FOR DISPOSAL, ACCORDING TO
HEALTH AND ENVIRONMENTAL REGULATIONS. CLEAN UP WITH WATER BEFORE ALLOWING TO
DRY.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
Handling And Storage Precautions: STORE BELOW 100 DEGREE F. KEEP FROM FREEZING.
Other Precautions: DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NON FLAMMABLE
Extinguishing Media: DRY CHEMICAL OR FOAM.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). NON-FLAMMABLE. WATER MAY BE USED TO COOL AND PROTECT
EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard: CLOSED CONTAINERS MAY BURST IF EXPOSED TO
EXTREME HEAT OR FIRE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: CONTROL ENVIRONMENTAL CONCS BELOW APPLIC STANDARDS.
WHERE RESP PROT IS REQUIRED, USE ONLY NIOSH APPRVD RESPIRATORS IN ACCORDANCE
WITH OSHA STANDARD 29 CFR 1910.134.
Ventilation: MAINTAIN ADEQUATE VENTILATION TO ENSURE AIR ENTRY DURING
APPLICATION & DRYING TO PREVENT BUILD-UP OF VAPORS.
Other Protective Equipment: ANSI APPRVD EYE WASH & DELUGE SHOWER (FP N). SKIN
CREAM (IF NEEDED).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >212F,>100C
Spec Gravity: 1.28-1.46(FP N)
Evaporation Rate & Reference: SLOWER/ETHYL ETHER
Solubility in Water: NOT KNOWN
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume: 51-54
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: ELEVATED TEMPERATURES. CONTACT WITH OXIDIZING
AGENTS.
Materials To Avoid: OXIDIZERS, ACIDS, BASES, AMINES.
Hazardous Decomposition Products: IF INVOLVED IN FIRE (FROM OTHER SOURCES)
COULD CONCEIVABLY RESULT IN RELEASE OF CARBON DIOXIDE & CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: FRESH KOTE HOUSE PAINT, 409875
Cage: HO637
Assigned IND: Y
Company Name: MA BRUDER & SONS INC
Street: 600 REED RD
Zipcode: 19008
Label Required IND: Y
Date Of Label Review: 03/31/1997
Status Code: C
Label Date: 03/31/1997
Origination Code: G
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE:INHALATION:IRRITATION OF RESPIRATORY TRACT.
PROLONGED INHALATION MAY LEAD TO MUCOUS MEMBRANE IRRITATION, DROWSINESS,
AND/OR LIGHT-HEADEDNESS, HEADACHE, NAUSEA. SKIN:IRRITATION. PROLONGED OR PREP
EATED CONTACT CAN CAUSE DERMATITIS. EYE:IRRITATION. PROLONGED OR REPEATED
CONTACT CAN CAUSE BLURRED VISION, CORNEAL INJURY. INGESTION:AMOUNTS INGESTED
INCIDENTAL TO CONSUMER & INDUST HANDLING ARE NOTLIKELY TO CAUSE INJURY;
HOWEVER; INGESTION OF LARGER AMOUNTS COULD CAUSE SERIOUS INJURY. CHRONIC:NONE
LISTED BY MANUFACTURER.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:EMBECO 885 GROUT
CAGE:FO873
CAGE:98898
CAGE:FO873
============= Composition/Information on Ingredients =============
Ingred Name:SILICATE, PORTLAND CEMENT; (PORTLAND CEMENT)
CAS:65997-15-1
RTECS #:VV8770000
Fraction by Wt: 30-60%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:CRYSTALLINE SILICA (PC); (SILICA CRYSTALLINE QUARTZ) (MFR)
(AMORPHOUS)
CAS:7631-86-9
Fraction by Wt: 10-30%
OSHA PEL:10 MG/M3 RDUST
ACGIH TLV:0.1 MG/M3 RDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL:NUISANCE DUST MAY CAUSE
TEMPORARY BUT REVERSIBLE RESPIRATORY PROBLEMS.EYES:ABRASIVE ACTION
MAY CAUSE DMG TO OUTER SURFACE OF THE EYE.MAY CAUSE SEVERE
IRRITATION WITH CORNEAL INJURY.SKIN:IN COMBI NATION WITH WATER
DERMAL EXPOS MAY CAUSE SEVERE ALKALI BURNS.SKIN ABSORP:NOT
APPLICABLE.INGEST:NOT (SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE: GROUP 2A (IARC).
Effects of Overexposure:HLTH HAZ:APPLICABLE.(CHRONIC)RPTD INHAL OF RESP
SILICA IN EXCESS OF THE TLV OVER EXTENDED PERIODS CAN RESULT IN
IRREVERSIBLE FIBROSIS OF THE LUNGS (SILICOSIS).THERE IS LIMITED
EVIDENCE OF CARCINOGENIC ITY OF CRYSTALLINE SILICA TO HUMANS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. EYES: FLUSH WITH COPIOUS AMOUNTS
OF WATER FOR AT LEAST 15 MINUTES. CONTACT MD. SKIN: WASH WITH SOAP
AND WATER. INGEST: CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:THIS MATL DOES NOT GIVE A FL PT BY CONVENTIONAL
TEST METHODS.USE EXTING AGENT SUITABLE FOR TYPE OF SURROUNDING
FIRE.
Fire Fighting Procedures:NOT APPLICABLE.
Unusual Fire/Explosion Hazard:NOT APPLICABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:NO SPECIAL PROCEDURES ARE REQUIRED FOR
CLEAN-UP OF SPILLS OR LEAKS OF THIS MATERIAL. SWEEP UP AND RETURN
FOR REUSE OR DISCARD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM WET DAMP CONDITIONS.
Other Precautions:DO NOT WEAR CONTACT LENSES WHEN WORKING WITH THIS
PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED DUST MASKS.
Ventilation:VENTILATION MAY BE USED TO CONTROL OR REDUCE AIRBORNE
CONCENTRATIONS.
Other Protective Equipment:NORMAL CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:SLIGHT
Appearance and Odor:DARK GRAY POWDER, ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS PRODUCT, WHEN DISCARDED OR DISPOSED OF, IS
NOT LISTED AS A HAZARDOUS WASTE IN FEDERAL REGULATIONS. DISPOSE IN
A LANDFILL IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SCREEN WASH,SW 184,LACQUER FILM/STANCIL FILLER REMOVER
CAGE:76708
CAGE:76708
CAGE:26290
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA 313) (CERCLA)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 50 - 55%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM; Z-2
ACGIH TLV:S, 50 PPM; 9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE (SARA 313) (CERCLA)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 25 - 30%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:750PPM/1000STEL;9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:DIACETONE ALCOHOL (4-HYDROXY-4-METHYL-2-PENTANONE)
CAS:123-42-2
RTECS #:SA9100000
Fraction by Wt: 15 - 20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:50 PPM
ACGIH TLV:50 PPM; 9596
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, CNS, LIVER,
KIDNEY, LUNG. ACUTE- EYE/SKIN:PRIMARY IRRITANT. INHALE:ANESTHETIC,
CNS DEPRESSION. REPEATED & PROLONGED OVEREXPOSURE BY
INHALATION/SKIN ABSORPTION MAY CAUSE LIVER, KIDNEY & BLOOD DAMAGE.
ORAL:MAY CAUSE VOMITING. ASPIRATION HAZARD. CHRONIC- DERMATITIS,
LIVER, KIDNEY, BRAIN DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DROWSINESS, DIZZINESS, NAUSEA,
VOMITING, HEADACHE, WEAKNESS, ABDOMINAL DISCOMFORT, DRYNESS OF
SKIN, DERMATITIS, ABDOMINAL PAIN, TEARING, BLURRED VISION, BURNING
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING
DISEASES OF THE EYE, SKIN, RESPIRATORY TRACT, LIVER, KIDNEYS, CNS
MAY HAVE INCREASED SUSCEPTIBILITY TO THE TOXICITY OF EXCESSIVE
EXPOSURES.
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15
MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP & WATER. ORAL:DO
NOT IN DUCE VOMITING. IF VOMITING OCCURS SPONTANEOUSLY, KEEP HEAD
BELOW HIPS TO PREVENT ASPIRATION OF LIQUID INTO THE LUNGS. GET
IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:<60F,<16C
Lower Limits:1.0%
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL/CARBON DIOXIDE. WATER
MAY BE INEFFECTIVE BUT SHOULD BE USED TO COOL FIRE-EXPOSED
CONTAINER
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. IF WATER IS USED, FOG NOZZLES
ARE PREFERRED.
Unusual Fire/Explosion Hazard:VAPOR IS HEAVIER THAN AIR AND CAN TRAVEL
CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK.
CONTAINERS MAY RUPTURE DUE TO VAPOR PRESSURE BUILDUP.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. CONTAIN AND PICK UP SPILL WITH
NON-FLAMMABLE ABSORBENT SUCH AS SAND, EARTH, VERMICULITE OR
NON-SPARKING TOOLS. PREVENT LIQUIDFROM ENTERING SEWERS OR
WATERWAYS.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, VENTILATED AREA AWAY
FROM IGNITION SOURCES. DO NOT STORE ABOVE 120F. STORE LARGE
QUANTITIES IN BUILDING DESIGNED FOR FLAMMABLE LIQUIDS.
Other Precautions:VERY FLAMMABLE. EMPTY CONTAINERS RETAIN RESIDUE.
FOLLOW ALL PRECAUTIONS. DO NOT GET IN EYES. DO NOT BREATHE VAPOR OR
MIST. AVOID PROLONGED OR REPEATED SKIN CONTACT. WASH THOROUGHLY
AFTER HANDLING. AVO ID INGESTION. KEEP OUT OF REACH OF CHILD
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF WORKING IN CONFINED AREAS, IF EXCESSIVE
MISTING IS EXPECTED OR IF EXPOSURE MAY OR DOES EXCEED RECOMMENDED
PERMISSIBLE EXPOSURE LIMITS (PEL), WEAR NIOSH-APPROVED RESPIRATORY
PROTECTION FOR ORGANIC V APORS (REFER TO 29 CFR 1910.134).
Ventilation:MECHANICAL (GENERAL AND/OR LOCAL EXHAUST, EXPLOSION-PROOF)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER,
INDUSTRIAL-TYPE WORK CLOTHING, APRON
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F3
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:131F - 340F
Vapor Density:>1
Spec Gravity:0.8523
VOC Grams/Liter:5.15
Evaporation Rate & Reference:<1 (ETHER=1)
Appearance and Odor:LIQUID, SOLVENT ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ALKALIS, REACTIVE METALS
Stability Condition to Avoid:HEAT, SPARKS, FLAMES AND OTHER SOURCES OF
IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, OTHER
NOXIOUS GASES MAY BE FORMED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE IN ACCORDANCE WITH LOCAL,
STATE AND FEDERAL REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.
RECYCLING OR REUSING IS RECOMMENDED.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:RECHARGEABLE BATTERY
CAGE:56309
CAGE:0FGN2
CAGE:56309
CAGE:0VMZ0
============= Composition/Information on Ingredients =============
Ingred Name:SULFURIC ACID (SARA III)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 17% %
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:LEAD (SARA III)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 60% %
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.05 MG/M3;1910.1025
ACGIH TLV:0.15 MG/M3;DUST 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:LEAD OXIDE
CAS:1314-41-6
RTECS #:OG5425000
Fraction by Wt: 20% %
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LC50 ORAL RAT= 2140 MG/KG
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES:THE ELECTROLYTE,SULFURIC
ACID,CAN CAUSE BURNS.INHAL:SULFUR OXIDE CAN CAUSE NASAL AND
RESPIRATORY IRRITATION.INGEST:CAN CAUSE STOMACH IRRITATION.
Explanation of Carcinogenicity:PRODUCT CONTAINS NO INGREDIENTS
CURRENTLY CLASSIFIED AS CARCINOGENIC BY NTP, IARC OR OSHA.
Effects of Overexposure:INHALED: NASAL AND RESPIRATORY IRRITATION FROM
SULFUR OXIDE FUMES. CONTACT WITH SKIN OR EYES: BURNS, SKIN
IRRITATION AND EYE DAMAGE. ABSORBED THROUGH SKIN: SKIN IRRITATION
AND BURNS. INGESTION: STOMAC H IRRITATION.
Medical Cond Aggravated by Exposure:NONE EXPECTED IN NORMAL USE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. GET MEDICAL
ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. FLUSH AREA WITH
WATER. GET MEDICAL ATTENTION IF IRRITATION PERSISTS. INHALATION:
REMOVE PATIENT TO F RESH AIR. DISCONNECT BATTERIES AND VENTILATE
AREA. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. INGESTION: DRINK
LARGE QUANTITIES OF WATER OR MILK, FOLLOWED BY MILK OF MAGNESIA.
GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.POLYSTYRENE CASE IS NO-FLAMMABLE(PER
UL94,VE-0 OR VE-1).
Unusual Fire/Explosion Hazard:KEEP AWAY FROM OPEN FLAMES AND SPARKS.
IMPROPER CHARGING AND IGNITION OF RESULTING GASES CAN CAUSE
EXPLOSION, PARTICULARLY IN GAS TIGHT ENCLOSURES.
================== Accidental Release Measures ==================
Spill Release Procedures:THE ELECTROLYTE, SULFURIC ACID, IS IMMOBILIZED
AND SEALED WITHIN A CLOSED SYSTEM AND IS NON-SPILLABLE. IF CASE IS
CRACKED AVOID CONTACT WITH SPILLED ELECTROLYTE. WRAP ENTIRE BATTERY
TIGHTLY IN POLYETH YLENE BAGS FOR PROPER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PHYSICAL DAMAGE. ADHERE TO
PROPER CHARGING PROCEDURES.
Other Precautions:DO NOT OVERCHARGE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED.
Ventilation:GENERAL (MECHANICAL) SHOULD BE SUFFICIENT.
Other Protective Equipment:PROTECTIVE CLOTHING ...AS NEEDED.
Work Hygienic Practices:WASH HANDS.SEPERATE WORK CLOTHES FROM STREET
CLOTHES.LAUNDER WORK CLOTHES BEFORE REUSE.KEEP FOOD OUT OF THE WORK
AREA.
Supplemental Safety and Health
PROTECT AGAINST CRACKING OF CASE MATERIAL. ADHERE TO PROPER CHARGING
PROCEDURES.
================== Physical/Chemical Properties ==================
HCC:Z4
Appearance and Odor:RECTANGULAR/SQUARE SHAPE;ORANGE;NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SOLVENTS MAY DISSOLVE CASE MATERIAL.
Stability Condition to Avoid:PHYSICAL DAMAGE,HIGH HEAT,FIRE,IMPROPER
CHARGING,SHORTING.
Hazardous Decomposition Products:HYDROGEN, OXYGEN, AND SULFUR OXIDE
FUMES.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE WITH AUTOMOTIVE SCRAP BATTERIES. DO NOT
INCINERATE. DISPOSE OF ALL WASTES IN ACCORDANCE WITH FEDERAL, STATE
AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DP-LUBRICANT BLUE, 1 LITRE
Preparer's Name:M.M./A.G.P.
CAGE:5T799
CAGE:5T799
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ALCOHOL; (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 70-85%
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ingred Name:ETHYLENE GLYCOL (SARA 313) (CERCLA)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 5-15%
OSHA PEL:N/K
ACGIH TLV:50 PPM, VAPOR, C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ISOPROPYL ALCOHOL; (2-ISOPROPANOL)(SARA 313)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 5-15%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM;500 STEL
Ingred Name:BLUE DYE
CAS:81457-64-9
RTECS #:9999999ZZ
Fraction by Wt: <0.1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPP DATA:UNCOMFORTABLE. SEEK HOSPITAL & BRING ALONG THESE
INSTRUCTIONS.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:COMBUST MATL. WATER SOLUBLE. WILL SPREAD IN
WATER SYSTEMS. SOLVS WILL EVAPORATE EASILY FROM ALL SURFACES.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ORGANIC SOLVS MAY BE ABSORBED INTO
BODY BY INHAL & INGEST & AFFECT NERV SYS. LIQ MAY IRRIT SKIN, EYES
& RESP TRACT. INHAL:VAPS MAY IRRIT THROAT & RESP SYS & CAUSE COUGH.
VAPS HAVE NARCOTIC EFT & MAY C AUSE HDCH, FATG, DIZZ & NAUS. IN
SERIOUS CASES, UNCON & DMG TO LIVER MAY BE SEEN. SKIN CONT:PRLNG
CONT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:CONT MAY CAUSE REDNESS & IRRIT.
CONTAINS PROPANOL WHICH MAY PENETRATE SKIN. EYE CONT:SPLASHES MAY
IRRITATE. INGEST:MAY IRRITATE & CAUSE MALAISE. ETHANOL MAY CAUSE
REPRO EFTS AT EVEN SMALL DOS ES.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE INTO FRESH AIR & KEEP AT REST. SKIN:REMOVE CONTAM
CLOTHES & RINSE SKIN THORO W/WATER. BURNS:FLUSH W/WATER IMMED.
WHILE FLUSHING, REMOVE CLOTHES WHICH DO NOT ADHERE TO AFFFECTED
AREAS. CALL AMBULANCE. CONTINUE FLUSHING DURING TRANSPORT TO
HOSPITAL. EYES:FLUSH W/PLENTY OF WATER FOR UP TO 15 MINS. REMOVE
ANY CONT LENSES & OPEN LIDS WIDELY. IF IRRIT PERSISTS; SEEK MED
ATTN & BRING (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:55.4F,13.0C
Lower Limits:3.2%
Upper Limits:19%
Extinguishing Media:EXTINGUISH W/FOAM, CARBON DIOXIDE, DRY POWDER,
WATER FOG OR ALCOHOL-RESISTANT FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . COOL CONTAINERS EXPOSED TO HEAT W/WATER SPRAY & REMOVE
CONTAINER, IF NO RISK IS INVOLVED.
Unusual Fire/Explosion Hazard:THIS PROD IS HIGHLY FLAMM & EXPLO VAP/AIR
MIXTS MAY BE FORMED EVEN AT NORMAL ROOM TEMPS. VAPS ARE HVR/AIR &
MAY TRAVEL ALONG FLOOR & IN BOTTOM OF (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:DO NOT SMOKE/USE OPEN FIRE/OTHER SOURCES OF
IGNIT. AVOID INHAL OF VAPS & CONT W/SKIN & EYES. AVOID DISCHARGE
INTO WATER COURSES/ONTO GROUND. LG QTYS SHOULD NOT BE DISCHARGED
INTO DRAIN BUT REMOVED W/A BSORBING MATL. DO NOT USE
SAWDUST/OTHER(ING 6)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL & WELL-VENTILATED
PLACE. STORE SEPARATELY FROM OXIDANTS. DO NOT SMOKE OR USE OPEN
FIRE OR OTHER SOURCES OF IGNITION.
Other Precautions:AVOID INHAL OF VAPORS & CONTACT W/SKIN & EYES. HIGHLY
FLAMMABLE. KEEP CONTAINER TIGHTLY CLOSED. KEEP AWAY FROM SOURCES OF
IGNITION - NO SMOKING. USER MUST BE INSTRUCTED IN PROPER WORK PROC
& BE FAMILI AR W/CONTENTS OF THESE INSTRUCTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN CASE OF INADEQUATE VENTILATION & WORK OF
BRIEF DURATION, USE SUITABLE NIOSH APPROVED RESPIRATORY EQUIPMENT
W/GAS-FILTER (CLASS A2).
Ventilation:PROVIDE ADEQUATE VENTILATION. OBSERVE OCCUPATIONAL EXPOSURE
LIMITS & MINIMIZE RISK OF INHALATION OF VAPORS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES.
Supplemental Safety and Health
EXPLO HAZ:CNTNRS. VAPS MAY BE IGNITED BY SPK, HOT SURF/EMBER. PROT
IN ADVISABLE. EYE PROT:FULL LGTH FSHLD . FIRST AID PROC:ALO NG
THESE INSTRUCTIONS. INGEST:IMMED RINSE MOUTH & DRINK PLENTY OF LIQ.
KEEP PERSON UNDER OBSERVATION. IF (ING 5)
================== Physical/Chemical Properties ==================
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR BLUE LIQUID; ALCOHOLIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:AVOID EXPOSING CONTAINERS TO HIGH
TEMPERATURES OR DIRECT SUNLIGHT.
Hazardous Decomposition Products:BY HEATING & FIRE, IRRITATING FUMES
MAY BE FORMED, INCLUDING CARBON MONOXIDE & CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . DISPOSE OF SPILLAGES & WASTE ACCORDING TO AGREEMENT
W/LOCAL AUTHORITIES.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:RP 4012 RESIN
Preparer's Name:M. MUNSELL
CAGE:02684
CAGE:02684
============= Composition/Information on Ingredients =============
Ingred Name:TALC (CONTAINING NO ASBESTOS)
CAS:14807-96-6
RTECS #:WW2710000
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST; 9192
Ingred Name:CALCIUM CARBONATE (MARBLE) (LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9192
Ingred Name:BISPHENOL A DIGLYCIDYL ETHER RESIN, EPOXY RESIN
CAS:25068-38-6
RTECS #:KC2100000
Ingred Name:PHENOL, POLYMER WITH FORMALDEHYDE, GLYCIDYL ETHER
CAS:28064-14-4
Ingred Name:VINYL CYCLOHEXENE DIOXIDE
CAS:106-87-6
RTECS #:RN8640000
Other REC Limits:A2 CARCINOGEN
OSHA PEL:S, 10 PPM
ACGIH TLV:S, 10 PPM ;A2; 9192
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE, SKIN & RESPIRATORY. SKIN:
ABSORPTION MAY CAUSE NAUSEA, VOMITING & OTHER SIGNS OF ILLNESS &
SENSITIZATION. INHALATION: HEATED PRODUCT MAY PRODUCE INHLALBLE
VAPORS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: PAINTING TESTS IN ANIMALS CAUSED CANCERS,
BUT NO CANCERS HAVE BEEN REPORTED IN HUMANS & MAY CAUSE ALLERGIC
REACTION. HARMFUL IF ABSORBED THROUGH SKIN.
Medical Cond Aggravated by Exposure:ALLERGIC SKIN REACTION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MINUTES. CALL PHYSICIAN.
SKIN: WASH W/SOAP & WATER. REMOVE CONTAMINATED CLOTHING & LAUNDER
BEFORE RE-USE. INGESTION: IF CONSCIOUS, GIVE PLENTY OF WATER TO
DRINK. DO N'T INDUCE VOMITING. CALL PHYSICIAN. INHALATION: REMOVE
TO FRESH AIR. GIVE OXYGEN/ARTIFICIAL RESPIRATION, IF NEEDED. CALL
PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:DECOMPOSITION & COMBUSTION PRODUCTS MAY
BE TOXIC.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SPILLAGE BY ABSORBING IN ABSORBENT
MATERIAL. DISPOSE OF IN CLOSED CONTAINER. FLUSH CONTAMINATED AREA
W/WATER. COLLECT WATER FOR PROPER DISPOSAL. AVOID CONTACT.
======================Handling and Storage ======================
Handling and Storage Precautions:HARMFUL IF ABSORBED THROUGH SKIN.
AVOID CONTACT W/EYES, SKIN, & CLOTHING. AVOID PROLONGED/REPEATED
CONTACT W/SKIN. WASH THOROUGHLY AFTER HANDLING.
Other Precautions:CANCER HAZARD BASED ON TESTS W/LABORATORY ANIMALS.
OVEREXPOSURE MAY CREATE CANCER RISK.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED ORGANIC VAPOR CARTRIDGE
RESPIRATOR WHEN VAPOR/MIST EXPOSURE.
Ventilation:MECHANICAL & LOCAL EXHAUST IN ACCORDANCE WITH ACGIH
RECOMMENDATIONS.
Other Protective Equipment:PROTECTIVE CLOTHING.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING/LAUNDER BEFORE RE-
USE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:T6
Boiling Pt:B.P. Text:>400F
Vapor Pres:.05
Spec Gravity:1.30-1.36
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRAY FILLED LIQUID, WITH DISTINCTIVE ODOR.
Percent Volatiles by Volume:<1%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS & BASES
Stability Condition to Avoid:EXCESSIVE HEAT FOR PROLONGED PERIODS OF
TIME.
Hazardous Decomposition Products:TOXIC MATERIALS, CO2, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT QUALIFIED LOCAL OR CORPORATE PERSONNEL
FOR METHOD THAT WILL COMPLY W/LOCAL, STATE, FEDERAL & REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LIONITE ALUMINUM OXIDE, SSC
CAGE:84330
CAGE:84330
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM OXIDE; (ALPHA-ALUMINA)
CAS:1344-28-1
RTECS #:BD1200000
Fraction by Wt: 96.4%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 2.7%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:SILICA GEL; (SILICON DIOXIDE)
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 0.5%
OSHA PEL:6 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:MAGNESIUM OXIDE
CAS:1309-48-4
RTECS #:OM3850000
Fraction by Wt: 0.2%
OSHA PEL:15 MG/M3 PARTICULATE
ACGIH TLV:10 MG/M3;TDUST; 9293
Ingred Name:IRON (III) OXIDE
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 0.1%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
Ingred Name:CALCIUM OXIDE
CAS:1305-78-8
RTECS #:EW3100000
Fraction by Wt: 0.1%
OSHA PEL:5 MG/M3
ACGIH TLV:2 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPOSURE TO EXCESSIVE AIRBORNE
CONCENTRATIONS MAY RESULT IN ACUTE RESPIRATORY DISORDERS.
INDIVIDUALS W/IMPAIRED PULMONARY FUNCTION SHOULD NOT BE SUBJECTED
TO EXCESSIVE AIRBORNE CONCENTRATIONS. SYMPTOM S OF EXCESSIVE
EXPOSURE MIGHT INCLUDE DEPOSITS OF MATERIAL IN EYES, EARS, NASAL
PASSAGES & IRRITATION (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:OF MUCOUS MEMBRANES, EYES &
RESPIRATORY TRACT. IRRITATION OF SKIN MAY ALSO OCCUR DUE TO
MECHANICAL/CHEMICAL ACTION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOSURE. SEE MD. EYE:IRRIGATE W/COPIOUS
QUANTITIES OF WATER FOR AT LEAST 15 MINUTES. SEE MD. SKIN:IRRIGATE
W/COPIOUS QUANTITIES OF WATER. SEE MD. INGEST:CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
================== Accidental Release Measures ==================
Spill Release Procedures:NORMAL PRECAUTIONS FOR INERT OR NUISANCE DUSTS
& PARTICULATES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE HANDLING PROCEDURES WHICH WILL
LIMIT EXPOSURE TO EXCESSIVE AIRBORNE DUST.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:UTILIZE NIOSH/MSHA APPROVED RESPIRATORY
PROTECTION DEVICES FOR NUISANCE DUST.
Ventilation:UTILIZE LOCAL EXHAUST TO KEEP AIRBORNE CONCENTRATION BELOW
TLV.
Other Protective Equipment:ARM SLEEVES OR BARRIER CREAMS MAY BE USEFUL
IN PREVENTION OF DERMATITIS.
Work Hygienic Practices:MAINTAIN NORMAL HOUSEKEEPING PROCEDURES FOR
NUISANCE DUST.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:3722F,2050C
Vapor Pres:0
Spec Gravity:3.95
Solubility in Water:INSOLUBLE
Appearance and Odor:LIGHT TO DARK BROWN; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE W/HOT CHLORINATED RUBBER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN COMPLIANCE W/ALL FEDERAL, STATE &
LOCAL LAWS & REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DASCOOL 4517
CAGE:96283
CAGE:96283
============= Composition/Information on Ingredients =============
Ingred Name:2-AMINOETHANOL, ETHANOLAMINE, MONOETHANOLAMINE
CAS:141-43-5
RTECS #:KJ5775000
Fraction by Wt: <5%
Other REC Limits:3 PPM
OSHA PEL:3 PPM
ACGIH TLV:7.5 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER. SKIN: WASH W/SOAP & WATER. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, FOAM, DRY CHEMICAL
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE SPILL & SOAK UP ON INERT ABSORBENT
MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE DRUMS CLOSED, AWAY FROM EXTREME
TEMPERATURES.
Other Precautions:DON'T ADD NITRITES.
============= Exposure Controls/Personal Protection =============
Work Hygienic Practices:USE GOOD PERSONAL HYGIENE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F
Spec Gravity:1.06
Evaporation Rate & Reference:(BU AC = 1): <1
Solubility in Water:COMPLETE
Appearance and Odor:AMBER LIQUID W/MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:AQUAPRIMER SURFACER WHITE, 882
CAGE:IO833
CAGE:0RGC9
CAGE:IO833
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIUM HYDROXIDE(SARA III). VP:420 @ 60F.
CAS:1336-21-6
RTECS #:BQ9625000
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:25 PPM (MFR)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 15%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:BARIUM SULFATE; (BARIUM COMPOUND)
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: 1%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:BENZOIC ACID, AMMONIUM SALT; (AMMONIUM BENZOATE) (SARA
III)
CAS:1863-63-4
RTECS #:DG3378000
Fraction by Wt: <0.5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHANOL, 2-BUTOXY-; (2-BUTOXYETHANOL) (SARA III). VP:0.8 @
68F.
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 7%
OSHA PEL:50 PPM, S
ACGIH TLV:25 PPM, S
Ingred Name:ETHANOL, 2-(2-BUTOXYETHOXY)-; (DIETHYLENE GLYCOL MONOBUTYL
ETHER)
CAS:112-34-5
RTECS #:KJ9100000
Fraction by Wt: 1%
OSHA PEL:50 PPM
ACGIH TLV:50 PPM
Ingred Name:PHTHALIC ACID, BENZYL BUTYL ESTER; (BUTYL BENZYL PHTHALATE)
(SARA III). VP:0.2 @ 300F.
CAS:85-68-7
RTECS #:TH9990000
Fraction by Wt: <5%
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:VOLATILE ORGANIC COMPOUNDS. %: COATING - 1.85 LB/GAL (234
G/L); MATERIAL - 0.97 LB/GAL (116 G/L).
RTECS #:9999999VO
Fraction by Wt: SEE ING
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:CONCENTRATED VAPORS MAY BE
HARMFUL. MAY CAUSE HEADACHE, DIZZINESS & NAUSEA. SKIN/EYE CONT:MAY
CAUSE IRRITATION. SKIN ABSORPTION:MAY CAUSE IRRITATION. INGEST:MAY
BE HARMFUL IF SWALLOWED. CH RONIC:ANIMAL STUDIES CLEARLY
DEMONSTRATED DOSE-RELATED ADVERSE EFFECTS ON THE CNS, HEMATOPOIETIC
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:TISSUES, BLOOD, KIDNEYS & LIVER,
ASSOCIATED W/ADMINISTRATION OF ETHYLENE GLYCOL MONOBUTYL ETHER
(EGBE). (EXTRACTED FROM DHHS (NIOSH) PUBLICATION NO.90-118) .
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN &
RESPIRATORY DISORDERS MAY BE AGGRAVATED.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. EYE:FLUSH IMMEDIATELY W/LARGE
AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. SKIN:WASH AFFECTED AREAS
W/SOAP & WATER. REMOVE CONTAMINATED CLOTHING. INGEST:DO NOT INDUCE
VOMITING. GET MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>200F,>93C
Lower Limits:0.3%
Upper Limits:10.6%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:MATL WILL NOT SUSTAIN COMBUST UNLESS
WATER IS EVAPORATED. FIRE-EXPOS CNTNRS SHOULD BE COOLED W/WATER TO
PVNT PRESS BUILD UP WHICH COULD RSLT IN CNTNR RUPTURE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION & PROVIDE
VENTILATION. LARGE SPILLS MAY BE SCOOPED UP NON-SPARKING TOOLS.
SMALL SPILLS MAY BE PICKED UP W/ABSORBENT MATERIALS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HIGH TEMPERATURES &
OPEN FLAMES. KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:DO NOT TAKE INTERNALLY. AVOID PROLONGED CONTACT
W/SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN CASE OF POOR VENTILATION, USE NIOSH/MSHA
APPROVED ORGANIC VAPOR MASK.
Ventilation:ADEQUATE VOLUME & PATTERN TO KEEP AIR CONTAMINANT
CONCENTRATION BELOW CURRENT APPLICABLE OSHA OR ACGIH'S TLV LIMITS.
Other Protective Equipment:EYE BATH & SAFETY SHOWER MEETING ANSI DESIGN
CRITERIA .
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING THE WASHROOM.
SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.4 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SOLUBLE
Appearance and Odor:WHITE LIQUID W/MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:EXCESSIVE HEAT & OPEN FLAMES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
DIOXIDE &/OR CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE IN TIGHTLY CLOSED CONTAINERS. INCINERATE
OR DISPOSE OF I/A/W LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BR95 ADHESIVE, PART B
Kit Part:Y
CAGE:0V7G8
CAGE:0V7G8
CAGE:84955
============= Composition/Information on Ingredients =============
Ingred Name:2,4,6-TRIS(DIMETHYLAMINO METHYL) PHENOL
CAS:90-72-2
RTECS #:SN3500000
Fraction by Wt: 8-13%
Other REC Limits:NONE RECOMMENDED
Ingred Name:IRON OXIDE
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 0.1-1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5MG(FE)/M3FUME,B2;95
Ingred Name:AMINE TERMINATED POLYMER
Fraction by Wt: 15-40%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYAMIDE
Fraction by Wt: 60-100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT, ESTIMATED) = >5 G/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:WARNING! MAY CAUSE ALLERGIC SKIN
REACTION! ALLERGIC SKIN REACTIONS OR PRIMARY SKIN IRRITATION MAY
BE PRODUCED BY PROLONGED &/OR REPEATED SKIN CONTACT.
Explanation of Carcinogenicity:MANUFACTURER GAVE NO INFORMATION ABOUT
CARCINOGENICITY. HMIS FOUND NO LISTING & DOES NOT EXPECT IT TO BE
CARCINOGENIC.
Effects of Overexposure:EYE, SKIN, RESPIRATORY IRRITATION
Medical Cond Aggravated by Exposure:MFR GAVE NO INFORMATION OF MSDS.
======================= First Aid Measures =======================
First Aid:IN CASE OF SKIN CONTACT IMMEDIATELY WAS AFFECTED AREAS W/SOAP
& PLENTY OF WATER. REMOVE CONTAMINATED CLOTHING & SHOES. GET
IMMEDIATE MEDICAL ATTENTION. DESTROY OR THOROUGHLY CLEAN SHOES
BEFORE REUSE. DO NOT REUSE CONTAMINATED CLOTHING W/O LAUNDERING.
IN CASE OF EYE CONTACT, IMMEDIATELY IRRIGATE W/PLENTY OF WATER FOR
15 MIN.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>200F,>93C
Autoignition Temp:Autoignition Temp Text:N/A.
Lower Limits:2
Upper Limits:6
Extinguishing Media:USE WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS & FULL
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SUITABLE PERSONAL PROTECTIVE CLOTHING
CHOSEN TO PROTECT FROM APPROPRIATE EXPOSURE. COVER SPILL W/INERT
ABSORBENT, SWEEP UP SPILLS & PLACE IN A WASTE DISPOSAL CONTAINER.
FLUSH AREAS W/WATER.
Neutralizing Agent:MFR GAVE NO INFORMATION OF MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PROLONGED &/OR REPEATED SKIN
CONTACT. WASH THOROUGHLY AFTER HANDLING.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PEL, USE
NIOSH RESPIRATOR APPROVED FOR THE MATERIAL & LEVEL OF EXPOSURE. FOR
CUTTING, SANDING, GRINDING CURED MATERIAL, RESPIRATOR FOR DUST
EXPOSURE MAY BE NECESSA RY.
Ventilation:USE LOCAL EXHAUST TO KEEP EXPOSURE <TLV WHEN SPRAYING OR
CURING AT ELEVATED TEMPERATURES. ..
Other Protective Equipment:IMPERVIOUS APRON, WORK PANTS, LONG SLEEVE
WORK SHIRT OR DISPOSABLE COVERALLS ARE RECOMMENDED. EYE WASH &
SAFETY SHOWER.
Work Hygienic Practices:DO NOT STORE, CARY OR CONSUME FOOD, BEVERAGES
OR TOBACCO PRODUCTS WHERE THIS MATERIAL IS IN USE.
Supplemental Safety and Health
WASH FACE & HANDS W/SOAP & WATER BEFORE EATING, DRINKING OR SMOKING.
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NONE
Boiling Pt:B.P. Text:N/A.
Melt/Freeze Pt:M.P/F.P Text:N/A.
Decomp Temp:Decomp Text:N/A.
Vapor Pres:1 MM
Vapor Density:N/A.
Spec Gravity:0.9
pH:N/A.
Evaporation Rate & Reference:N/A.
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER TO RED LIQUID, AMINE ODOR
Percent Volatiles by Volume:N/A.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENT, MINERAL ACIDS
Stability Condition to Avoid:NONE NOWN
Hazardous Decomposition Products:THERMAL DECOMOSITION OR CIMBUSTION MAY
PRODUCE CARBON MONOXIDE, CARBON DIOXIDE & NOX.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W APPLICABLE FEDERAL, STATE
& LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:405AB 1/4IN,CHOPPED CONTINUOUS STRANDS
CAGE:45255
CAGE:45255
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 98.0%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:ORGANOSILANE SIZING
Fraction by Wt: 2.0%
===================== Hazards Identification =====================
Effects of Overexposure:EYE:DIRECT CONTACT CAUSES MECHANICAL IRRITAT;
SKIN: TRANSITORY DERMATITIS; INHAL : NUISANCE DUST
======================= First Aid Measures =======================
First Aid:EYE: FLUSH WITH FLOWING WATER(EYE FOUNTAIN)FOR AT LEAST 15
MINUTES; SKIN: FREQUENT RINSING OF SKIN SURFACES W/WATER TO REMOVE
ACCUMULATED FIBERS WILL MINIMIZE IRRITATION.
================== Accidental Release Measures ==================
Spill Release Procedures:NO SPECIAL PRECAUTIONS REQUIRED
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN COOL DRY PLACE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED; USE RESPIRATOR IF DUST
CONC. EXCEEDS TLV.
Ventilation:SUFFICIENT TO MINIMIZE DUST FORMATON & MAINTAIN LEVEL < TLV
Other Protective Equipment:NONE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:OFF-WHITE;NO ODOR;SOLID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:AN INERT SOLID WASTE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ENAMEL, NONFLAMING (DRY) CHLORINATED ALKYD SEMI-GLOSS
CAGE:1BH90
CAGE:1BH90
============= Composition/Information on Ingredients =============
Ingred Name:BARIUM METABORATE
CAS:13701-59-2
Fraction by Wt: 15.0%
Other REC Limits:5 MG/M3
OSHA PEL:TOTAL DUST
ACGIH TLV:TOTAL DUST
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 21.0%
Other REC Limits:10 MG/M3
OSHA PEL:TOTAL DUST
ACGIH TLV:TOTAL DUST
Ingred Name:ZINC PHOSPHATE
CAS:7779-90-0
RTECS #:TD0590000
Fraction by Wt: 16.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYMER BASE CHLOROENDIC ALKYLOID
RTECS #:BP1008526
Code:F
Fraction by Wt: 35.0%
Ingred Name:TRADE SECRET: REGISTRY #41-0177680-5000 381 P (NJAPA)
RESIN SOLUTION
RTECS #:RS1010182
Code:F
Ingred Name:PAINT THINNER
CAS:8052-41-3
Fraction by Wt: 9.0%
OSHA PEL:100 PPM TWA
ACGIH TLV:100 PPM TWA
Ingred Name:DRIERS
CAS:136-52-7
Fraction by Wt: 3.0%
Ingred Name:LEVELING AGENT
RTECS #:LA1001685
Code:F
Ingred Name:ANTISKINNING AGENT
Fraction by Wt: 1.0%
Ingred Name:THIXATROPIC AGENT
RTECS #:TA1000608
Code:F
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:ACUTE: EYES: SEVERE IRRITATION. SKIN:
PRIMARY IRRITATION. HARMFUL IF ABSORBED THRU SKIN.
PROLONGED/REPEATED CONTACT: ALLERGIC SKIN REACTION. INHAL: HARMFUL
IF INHALED. IRRITATES EYES/NOSE/THROAT & LU NGS. HIGH VAPOR
CONCENTRATIONS MAY CAUSE IRRITATION OF RESPIRATORY SYSTEM &
PERMANENT BRAIN/NERVOUS SYSTEM DAMAGE. INTENTIONAL MIUSE CAN BE
HARMFUL OR FATAL. CHRONIC: AVOID LONG TERM/REPEATED CONTACT .
Explanation of Carcinogenicity:SEE TOXICOLOGICAL SECTION FOR DETAILS
Effects of Overexposure:EYE WATERING, HEADACHES, NAUSEA, DIZZINESS,
LOSS OF COORDINATION ARE INDICATIONS THAT SOLVENT LEVELS ARE TOO
HIGH. REDNESS/ITCHING/BURNING SENSATION/VISUAL DISTURBANCES MAY
INDICATE EXCESSIVE EYE CONT ACT. DRINESS/ITCHING/CRACKING/BURNING
REDNESS/SWELLING: EXCESSIVE SKIN CONTACT.
======================= First Aid Measures =======================
First Aid:IF SWALLOWED: GIVE 1 OR 2 GLASSES OF WATER. DO NOT INDUCE
VOMITING. KEEP PERSON WARM, QUIET, AND GET IMMED MEDICAL ATTEN.
EYES: FLUSH WITH WATER FOR 30 MINUTES, LIFTING LIDS TO RINSE ENTIRE
EYE. CALL DR IMMED. SKIN: FLUSH W/COPIOUS AMOUNTS OF WATER, THEN
FOLLOW W/ SOAP & WATER. CALL DR. INHALATION: REMOVE TO FRESH AIR.
APPLYSUPPORTIVE MEASURES AS REQUIRED. OTHER: IF INGEST: ANY TYPE
OF OVEREXPO SURE/SYMPTOMS OF OVEREXPOSURE OCCUR DURING/FOLLOWING
USE OF PRODUCT, CONTACT POISON CONTROL CENTER, EMERENCY ROOM, OR
PHYSICIAN IMMED. HAVE MSDS INFO AVAILABLE.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:=40.6C, 105.F
Autoignition Temp:Autoignition Temp Text:NA
Extinguishing Media:USE NATIONAL FIRE PROTECTION ASSOCIATION (NFPA)
CLASS B EXTINGUISHERS (FOAM, CO2, DRY CHEMICAL) DESIGNED TO
EXTINGUISH NFPA CLASS IC FLAMMABLE LIQUID FIRE.
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. WATER SPRAY
MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT PRESSURE BUILD UP
AND POSSIBLE AUTOIGNITION OR EXPLOSION WHEN EXPOSED TO EXTREME
HEAT. IF WATER IS USED, FO G NOZZLES ARE PREFERABLE. FIRE FIGHTERS
WEAR SCBA.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS, OPEN FLAMES. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT. DO NOT APPLY
ON HOT SURFACES. TOXIC GASES MAY FORM WHEN PRODUCT IS CONTACTED BY
FLAME OR HOT SURFACES.
================== Accidental Release Measures ==================
Spill Release Procedures:PROVIDE MAXIMUM VENTILATION. ONLY PERSONEL
AREA. REMOVE ALL SOURCES OF IGNITION. PICK UP SPILLED MATERIAL
W/SAWDUST, VERMICULITE, OR OT HER ABSORBENT & PLACE INTO CONTAINERS
FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. STORE LARGE
QUANTITIES IN BUILDING DESIGNED AND PROTECTED FOR STORAGE OF NFPA
CLASS IC FLAMMABLE LIQUIDS.
Other Precautions:IF THIS MATERIAL IS PART OF A MULTIPLE COMPONENT
SYSTEM, READ THE MATERIAL SAFETY DATA SHEET FOR THE OTHER
COMPONENT(S) BEFOER BLENDING, AS THE RESULTING MIXTURE MAY HAVE THE
HAZARDS OF ALL OF ITS PAR TS. CONTAINERS SHOULD BE GROUNDED WHEN
POURED. AVOID FREE FALL OF LIQUIDS IN EXCESS OF FEW INCHES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ENSURE VENTILATION CONTROLS, VAPOR EXHAUST, OR
FRESH AIR ENTRY. NIOSH/MSHA APPROVED 9TC-23C AIR PURIFYING OR AIR
SUPPLIED TC-19C RESPIRATORS MAY ALSO REDUCE EXPOSURE.
Ventilation:GENERAL DILUTION OR LOCAL EXHAUST VENTILATION IN VOLUME AND
PATTERNED TO KEEP INGREDIENTS BELOW SUGGESTED LIMITS IN THIS MSDS.
Other Protective Equipment:CLEAN OR DISCARD CONTAMINATED CLOTHING AND
SHOES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:310 TO 390 F @ 760 MM
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:2.00 MM HG @ 68 F
Vapor Density:4.9 AIR =1
Spec Gravity:1.62 - 1.65
VOC Pounds/Gallon:340
pH:NA
VOC Grams/Liter:2.8
Corrosion Rate:NA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, STRONG MINERAL ACIDS, OR STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:MAY PRODUCE HAZ DECOMP PRODUCTS WHEN
HEATED. WELDING, BRAZING, OR FLAME CUTTING MAY PRODUCE FUMES,
INCLUDING CABON MONOXIDE, HYDROGEN CHLORIDE GAS.
=================== Toxicological Information===================
Toxicological Information:AVOID LONG TERM AND REPEATED CONTACT. THIS
PRODUCT CONTAINS TITANIUM DIOXIDE. ANIMALS INHALING MASSIVE
QUANTITIES OF TITANIUM DIOXIDE DUST IN A LONG TERM STUDY DEVELOPED
LUNG TUMORS. STUDIES W/ HUMANS INVOLVED W/ MANUFACTURE OF THIS
PIGMENT INDICATE NO INCREASED RISK OF CANCER FROM EXPOSURE.
POTENTIAL FOR INHALATION OF TITANIUM DIOXIDE DUSTS FROM COATINGS IS
VERY LIMITED. SINCE OVEREXPOSURES ARE N OT EXPECTED, THERE ARE NO
SIGNIFICANT HAZARD FOR MAN. *CONTINUED UNDER ECOLOGICAL SECTION
===================== Ecological Information =====================
Ecological:THIS PRODUCT CONTAINS A LOW LEVEL OF FORMALDEHYDE ON THE
BASIS OF LONG TERM EXPOSURE OF ANIMALS TO HIGH LEVELS NTP, IARC,
AND OSHA ASSOCIATE FORMALDEHYDE WITH AN INCREASED RISK OF CANCER.
RECENT STUDI ES WITH HUMANS SHOW NO CORRELATION BETWEEN EXPOSURE TO
FORMALDEHYDE AND INCREASED CANCER RISK.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE W/LOCAL, STATE, FEDERAL
REGULATIONS. EMPTY CONTAINERS SHOULD BE RECYCLED OR DISPOSED OF
THROUGH APPROVED WASTE MANAGEMENT FACILITY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:COMPOUND CLEANING LIQUID (ML-20), 8511
Preparer's Name:L. ANDERSON
CAGE:FO323
CAGE:1G327
CAGE:FO323
============= Composition/Information on Ingredients =============
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: DIRECT CONTACT WILL CAUSE
BURNING, TEARING & REDNESS. SKIN: PRLNGD/RPTD SKIN CONTACT CAN
CAUSE MODERATE IRRITATION, DEFATTING, &/OR DERMATITIS.
INHAL:PRLNGD/RPTD BRTHG OF VERY HIGH VAP CONC MAY CAUSE HEADACHES,
NAUSEA & VOMITING. CHRONIC OVEREXPOSURE IN HIGH CONC MAY PRODUCES
CNS DEPRESSION. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: CHRONIC OVEREXPOSURE TO SOLVENT DPM
IN HIGH CONCENTRATIONS HAS CAUSED KIDNEY & LIVER DAMAGE IN
LABORATORY ANIMALS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:EYE:GENTLY FLUSH W/LRG QTYS OF WATER FOR AT LEAST 15 MIN &
SEEK IMMEDIATE MEDICAL ATTN. SKIN:REMOVE CONTAM CLTHG (WASH BEFORE
RE-USE), WASH AFFECTED SKIN AREAS W/SOAP & WATER, & SEEK MED ATTN
IF IRRIT PERSITS. INHAL:IF BRTHG IS DFCLT,
DIZZINESS/LIGHT-HEADEDNESS OCCUR WHEN WORKING IN AREAS W/HIGH VAP
CONC, VICTIM SHLD SEEK FRESH AIR. IF BRTHG STOPS, GIVE ARTF RESP &
SEEK IMMED MED ATTN. (SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:105F,41C
Extinguishing Media:USE WATER SPRAY, FOAM, CO*2, OR DRY CHEMICAL FIRE
FIGHTING APPARATUS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . USE WATER SPRAY TO COOL NEARBY CONTAINERS
AND STRUCTURES EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:KEEP WORK AREAS FREE OF HOT METAL
SURFACES AND OTHER SOURCES OF IGNITION.
================== Accidental Release Measures ==================
Spill Release Procedures:STAY UPWIND & AWAY FROM SPILL UNLESS WEARING
APPROP PROT EQUIP. STOP &/OR CNTN DISCHARGE IF IT MAY BE DONE
SAFELY. KEEP ALL SOURCES OF IGNIT AWAY; USE NON-SPARKING TOOLS FOR
CLEANUP. VENT AREA OF SPIL L & COVER W/INERT MATL TO REDUCE
FUMES.(SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP PROD CNTNRS COOL, DRY AND AWAY
FROM SOURCES OF IGNITION. USE & STORE THIS PROD W/ADEQ VENT. KEEP
PROD CNTNRS CLSD WHEN NOT IN USE.
Other Precautions:PERSONNEL SHLD AVOID INHAL OF VAPS. PERSONAL CNTCT
W/PROD SHLD BE AVOIDED. CNTNRS, EVEN EMPTY, MAY RETAIN PROD
RESIDUES &/OR VAPS. OBSERVE ALL HAZ PREC GIVEN IN THIS DATA SHEET.
VAPS OF THIS PROD ARE HVR/AIR & WILL COLLECT IN LOW PLACES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:THE USE OF RESP PROT DEPENDS ON VAP CONC ABOVE
THE TLV, USE NIOSH/MSHA APPROVED RESP/GAS MASK WITH APPROPRIATE
CARTRIDGES OR CANISTER OR NIOSH/MSHA APPROVED SUPPLIED AIR
EQUIPMENT, DEPENDING ON AIRBOR NE CONCENTRATION.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:THE AVAILABILITY OF EYE WASHES AND SAFETY
SHOWERS IN WORK AREAS IS RECOMMENDED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: INGEST: DO NOT INDUCE VOMITING; SEEK MEDICAL ATTN
IMMED. SPILL PROC: KEEP OUT OF DRAINS, SEWERS OR WATERWAYS. CONTACT
FIRE AUTHORITIES, NOTIFY LOCAL HEALTH AND POLLUTION CONTROL AGENCI
ES, AND CALL SPILL RESPONSE TEAMS IF LARGE SPILL.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:>301F,>149C
Vapor Pres:2.5 @ 68F
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN BUTY ACETATE
Solubility in Water:EMULSIFIES
Appearance and Odor:CLEAR, YELLOW LIQUID, MILD CITRUS ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS OR BASES.
Stability Condition to Avoid:EXTREME HEAT, SPARKS, AND OPEN FLAME.
Hazardous Decomposition Products:THERMAL DECOMPOSITION IN THE PRENSENCE
OF AIR MAY YIELD CARBON MONOXIDE AND/OR CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF PRODUCT IN ACCORDANCE WITH APPLICABLE
LOCAL, COUNTY, STATE, FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:2611, LIQUID SPRAY DEVELOPER LD3 AEROSOL (SEE SUPPL)
Preparer's Name:NOT PROVIDED
CAGE:K2063
Contract Num:SP0450-01-M-ZC84
CAGE:0A272
CAGE:K2063
============= Composition/Information on Ingredients =============
Ingred Name:PROPAN 2-OL (IPA)
CAS:67-63-0
RTECS #:NT8050000
< Wt:50.
Other REC Limits:NOT PROVIDED
OSHA PEL:980 MG/M3;400 PPM
ACGIH TLV:983 MG/M3;400 PPM
ACGIH STEL:1230 MG/M3;500 PPM
Ingred Name:LPG (FOR AEROSOLS)
CAS:68476-86-8
> Wt:50.
Other REC Limits:1000 PPM (MFR)
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: ORAL, RAT > 2 G/KG
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: WILL CAUSE IRRITATION AND MAY
CAUSE TISSUE DAMAGE IF NOT REMOVED PROMPTLY. SKIN: MAY CAUSE
DE-FATTING IF CONTACT IS PROLONGED OR FREQUENT. VAPOUR
CONCENTRATIONS ABOVE RECOMMENDED EXPOSURE LEVELS ARE IRRITATING TO
THE EYES AND THE RESPIRATORY TRACT. MAY CAUSE HEADACHES, DIZZINESS,
DROWSINESS AND NAUSEA AND EVENTUAL UNCONSCIOUSNESS. INGESTION: MAY
CAUSE NAUSEA. SMALL AMOUNTS OF LIQUID ASPIRATED INTO THE
RESPIRATORY SYSTEM DURING INGESTION OR FROM VOMITING MAY CAUSE
BRONCHOPNEUMONIA OR PULMONARY EDEMA.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYE: WILL CAUSE IRRITATION. SKIN: MAY CAUSE
DE-FATTING IF CONTACT IS PROLONGED OR FREQUENT. VAPOUR
CONCENTRATIONS ABOVE RECOMMENDED EXPOSURE LEVELS ARE IRRITATING TO
THE EYES AND THE RESPIRATORY TRACT . MAY CAUSE HEADACHES,
DIZZINESS, DROWSINESS AND NAUSEA AND EVENTUAL UNCONSCIOUSNESS.
INGESTION: MAY CAUSE NAUSEA.
Medical Cond Aggravated by Exposure:NOT PROVIDED
======================= First Aid Measures =======================
First Aid:EYE: IRRIGATE IMMEDIATELY WITH COPIOUS QUANTITIES OF CLEAN
WATER FOR 15 MINUTES WHILE HOLDING EYES OPEN. OBTAIN MEDICAL
ATTENTION IF IRRITATION PERSISTS. SKIN: WASH THE AFFECTED AREA
THOROUGHLY WITH M ILD SOAP AND WATER. FLUSH SKIN WITH LUKEWARM
WATER. INHALATION: IMMEDIATELY REMOVE FROM EXPOSURE. IF PERSON IS
OVERCOME BY FUMES OBTAIN, EMERGENCY MEDICAL ATTENTION. GIVE
ARTIFICIAL RESPIRATION IF REQ UIRED. REST AFFECTED PERSON KEEP
WARM. INGESTION: GIVE WATER TO DRINK IF CONSCIOUS. IF UNCONSCIOUS
OBTAIN EMERGENCY MEDICAL ATTENTION. DO NOT INDUCE VOMITING. OBTAIN
MEDICAL ATTENTION IF SIGNIFICANT Q UANTITY WAS INGESTED.
===================== Fire Fighting Measures =====================
Flash Point:=11.C, 51.8F
(PROPAN-2-OL)
Extinguishing Media:SUITABLE EXTINGUISHING MEDIA: CARBON DIOXIDE, DRY
POWDER, SAND OR FOAM, USE WATER SPRAY FOG TO KEEP THE AEROSOLS
COOL. UNSUITABLE EXTINGUISHING MEDIA: WATER JET.
Fire Fighting Procedures:BREATHING APPARATUS MUST BE WORN IF FIRE IS IN
A CONFINED SPACE.
Unusual Fire/Explosion Hazard:PRESSURIZED CONTAINERS MAY BURST AT
ELEVATED TEMPERATURES RELEASING HIGHLY FLAMMABLE MATERIAL.
================== Accidental Release Measures ==================
Spill Release Procedures:EXTINGUISH OR TURN OFF ALL SOURCES OF
MASK. ENSURE ADEQUATE VENTILATION OR WEAR A RESPIRATOR. STOP
RELEASE. CONTAIN SPILL WITH SUITABLE BOOM OR ABSORBENT GRANULES.
PREVENT ESCAPE TO DRAINS OR SEWERS. REPORT ANY MAJOR ESCAPE INTO
DRAINS TO FIRE AND WATER AUTHORITIES. SWEEP UP WITH ABSORBENT
COMPOUND AND HOLD FOR PROPER DISPOSAL.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A WELL VENTILATED COVERED
STORAGE AREA, OUT OF DIRECT SUNLIGHT AND DO NOT EXPOSE TO
TEMPERATURES ABOVE 50 DEG C. MIMIMIZE SKIN CONTACT BY USE OF PVC OR
PROTECTION. DO NOT SMOKE WHILE HANDLING THIS PRODUCT.
Other Precautions:DO NOT USE NEAR SOURCES OF IGNITION. AVOID BREATHING
VAPORS. IF THIS PRODUCT MUST BE USED IN AREAS WHERE GOOD
VENTILATION IS NOT AVAILABLE, WEAR SUITABLE RESPIRATORY EQUIPMENT.
WASH HANDS THOROUGHLY A FTER HANDLING THIS PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ENSURE GOOD VENTILATION. ABSORBENT MASKS OR
RESPIRATORS WILL BE REQUIRED IF VAPOUR BUILDUP OCCURS.
Ventilation:NOT PROVIDED
Other Protective Equipment:LONG SLEEVED OVERALLS ARE RECOMMENDED, ALSO
IMPERVIOUS APRONS AND GAUNTLETS IF THERE IS A RISK OF FREQUENT
CONTACT.
Work Hygienic Practices:NOT PROVIDED
Supplemental Safety and Health
CONTD FROM PRODUCT ID: PART NUMBER FOR R. G. DUNN & ASSOC.: SAE/AMS
2644A,TYPE E.
================== Physical/Chemical Properties ==================
HCC:F2
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:NOT PROVIDED
Melt/Freeze Pt:M.P/F.P Text:NOT PROVIDED
Decomp Temp:Decomp Text:NOT PROVIDED
Vapor Pres:NOT PROVIDED
Spec Gravity:0.9
Viscosity:NOT PROVIDED
Evaporation Rate & Reference:NOT PROVIDED
Solubility in Water:NOT PROVIDED
Appearance and Odor:WHITE VOLATILE, MOBILE LIQUID SUSPENSION
Percent Volatiles by Volume:NOT PROVIDED
Corrosion Rate:NOT PROVIDED
================= Stability and Reactivity Data =================
MAY DISSOLVE, STAIN, OR SOFTEN PAINTS, ORGANIC COATINGS OR RUBBERS
Stability Condition to Avoid:SOLIDS SETTLE ON STANDING. SHAKE BEFORE
USE. DO NOT EXPOSE TO STRONG OXIDIZING AGENTS, NAKED FLAMES OR
OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:OXIDES OF CARBON
=================== Toxicological Information===================
Toxicological Information:LD50 (ORAL, RAT) > 2,000 MG/KG
===================== Ecological Information =====================
Ecological:ENVIRONMENTAL MOBILITY: SOLID IS NOT HAZARD. THE LIQUID IS
VOLATILE AND WILL EVAPORATE TO AIR. ENVIRONMENTAL DEGRADABILITY:
LIQUID IS READILY BIODEGRADABLE. ECOTOXICITY: LOW ACUTE TOXICITY TO
AQAUTIC ORGANISMS IS EXPECTED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH LOCAL AND
NATIONAL LEGISLATION. THIS WILL NORMALLY BE THROUGH AN AUTHORIZED
CONTRACTOR TO A LICENSED SITE. TREAT ABSORBENT GRANULES AS HIGHLY
FLAMMABLE WASTE. PRESS URIZED CONTAINERS MUST BE PUNCTURED IN
SUITABLE RETAINING EQUIPMENT. LIQUID MAY THEN BE DISPOSED OF BY
INCINERATION IN A LICENSED FACILITY.
=================== MSDS Transport Information ===================
Transport Information:PROPER SHIPPING NAME: AEROSOLS, FLAMMABLE. UN
1950, CLASSIFICATION: FLAMMABLE GAS.
===================== Regulatory Information =====================
SARA Title III Information:NOT PROVIDED
Federal Regulatory Information:NOT PROVIDED
State Regulatory Information:NOT PROVIDED
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SORBITRATE TABLETS
CAGE:13992
)
CAGE:13992
============= Composition/Information on Ingredients =============
Ingred Name:ISOSORBIDE DINITRATE MIXTURE
CAS:87-33-2
RTECS #:LZ4386000
Other REC Limits:S, 0.2 MG/M3 TWA
Ingred Name:OTHER INGREDIENTS (MANUFACTURER STATES INGREDIENTS NOT
PRECISELY IDENTIFIED ARE PROPIETARY OR NONHAZARDOUS)
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS 945 MG/KG
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ISOSORBIDE DINITRATE IS A
METHEMOGLOBIN FORMER, AND MAY CAUSE GASTROINTESTINAL DISTURBANCES
AND CENTRAL NERVOUS SYSTEM DEPRESSION. A SINGLE DOSE OF THIS
PRODUCT IS SLIGHTLY TOXIC BY INGESTION. THE LIF E-THREATENING DOSE
IN MAN IS PROBABLY AROUND 2.5 G/KG.
Explanation of Carcinogenicity:NONE OF THE CHEMICALS IN THIS PRODUCT IS
LISTED BY IARC, NTP OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYES:NO IRRITATION LIKELY TO DEVELOP. SKIN:NO
IRRITATION LIKELY TO DEVELOP. INHALATION:TABLETS ARE NOT LIKELY TO
BE INHALED, BUT ANY DUST CAN BE SLOWLY ABSORBED THROUGH MUCOUS
MEMBRANES.
Medical Cond Aggravated by Exposure:NONE NOTED.
======================= First Aid Measures =======================
First Aid:EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES.SEE DOCTOR. SKIN:WASH WITH SOAP AND WATER.
INHALATION:REMOVE TO FRESH AIR.GIVE OXYGEN/CPR IF NEEDED.SEE
DOCTOR. INGESTION:GIVE 1 OR 2 GLASSES OF WATER.INDUCE VOMIT.SEE
DOCTOR. NOTE TO PHYSICIAN:SEVERE OVEREXPOSURE CAN, IN THEORY, LEAD
TO METHEMOGLOBIN FORMATION, WHICH IN SUFFICIENT CONCENTRATIONS
RESULTS IN CLINICAL CYANOSIS.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:CONCENTRATED ISOSORBIDE IS A POWERFUL
EXPLOSIVE.ANY SEPARATION OF IT FROM OTHER INGREDIENTS IN THE
MIXTURE,EVEN IN SMALL AMOUNTS IS EXTREMELY HAZARDOUS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SKIN PROTECTION DURING CLEANUP. SWEEP UP
AND RECOVER. WET MATERIAL WITH WATER IN A PLASTIC BAG OR PLASTIC
LINED CONTAINER. WHEN TABLETS BEGIN TO DISINTEGRATE, DISCARD WITH
GENERAL TRASH. FLUSH RE SIDUE WITH LARGE AMOUNTS OF WATER.
Neutralizing Agent:NONE APPLICABLE FOR THIS MATERIAL
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE, HEAT AND IGNITION SOURCES. KEEP
CONTAINERS CLOSED.
Other Precautions:AVOID BREATHING DUST. PREVENT SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:NORMAL ROOM VENTILATION.
Other Protective Equipment:NONE NORMALLY REQUIRED.
Work Hygienic Practices:WASH THROUGHLY AFTER HANDLING AND BEFORE
EATING.
Supplemental Safety and Health
NONE.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:158F,70C
Solubility in Water:SLIGHT
Appearance and Odor:TABLETS
Percent Volatiles by Volume:NEGL.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, ACIDS, ALKALIES, OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, PERCUSSION.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS. DISCARDED PRODUCT IS
NOT A HAZARDOUS WASTE UNDER RCRA. EMPTY CONTAINERS CONTAINS
RESIDUE, DO NOT REUSE.DESTR OY EMPTY CONTAINER BEFORE DISPOSAL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:XENON
CAGE:36346
Contract Num:SP0440-96-M-7875
CAGE:049X3
CAGE:36346
============= Composition/Information on Ingredients =============
Ingred Name:XENON
CAS:7440-63-3
RTECS #:ZE1280000
= Wt:100.
Ingred Name:ACTIVATED CARBON (TINY AMOUNT IN THE BULB)
CAS:7440-44-0
RTECS #:FF5250000
Fraction by Wt: TINY AMOUN
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Health Hazards Acute and Chronic:SWALLOWING - THIS PRODUCT IS A GAS AT
NORMAL TEMPERATURE AND PRESSURE. SKIN ABSORPTION - NO EVIDENCE OF
ADVERSE EFFECTS FROM AVAILABLE INFORMATION. INHALATION -
ASPHYXIANT. MODERATE CONCENTRATIONS MAY CAUSE HEADACHE,
DROWSINESS, DIZZINESS, EXCITATION, EXCESS SALIVATION, VOMITING, AND
UNCONSCIOUSNESS. LACK OF OXYGEN CAN CAUSE DEATH. SKIN CONTACT - NO
HARMFUL EFFECT EXPECTED FROM VAPOR. LIQUID MAY C AUSE FROSTBITE.
EYE CONTACT - NO HARMFUL EFFECT EXPECTED FROM VAPOR. LIQUID MAY
CAUSE FROSTBITE. CHRONIC -NO EVIDENCE OF ADVERSE EFFECTS FROM
AVAILABLE INFORMATION.
Medical Cond Aggravated by Exposure:THE TOXICOLOGY AND THE PHYSICAL AND
CHEMICAL PROPERTIES OF THE MATERIAL DO NOT SUGGEST THAT
OVEREXPOSURE IS LIKELY TO AGGRAVATE EXISTING MEDICAL CONDITIONS.
======================= First Aid Measures =======================
First Aid:SWALLOWING - THIS PRODUCT IS A GAS AT NORMAL TEMPERATURE AND
PRESSURE. SKIN CONTACT - FOR EXPOSURE TO LIQUID, IMMEDIATELY WARM
FROSTBITE AREA WITH WARM WATER (NOT EXCEED 105 F). IN CASE OF
MASSIVE EXP OSURE, REMOVE CLOTHING WHILE SHOWERING WITH WARM WATER.
CALL A PHYSICIAN. INHALATION - REMOVE TO FRESH AIR. GIVE
ARTIFICIAL RESPIRATION IF NOT BREATHING. GIVE OXYGEN IF BREATHING
IS DIFFICULT. CALL A PHYSICIAN. EYE CONTACT - IN CASE OF SPLASH
CONTAMINATION, IMMEDIATELY FLUSH EYES THOROUGHLY WITH WATER AT
LEAST FOR 15 MINUTES. SEE A PHYSICIAN, PREFERABLY AN
OPHTHALMOLOGIST, IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:XENONE CANNOT CATCH FIRE. USE MEDIA APPROPRIATE FOR
SURROUNDING FIRE.
Fire Fighting Procedures:EVACUATE ALL PERSONNEL FROM DANGER AREA.
IMMEDIATELY DELUGE CONTAINERS WITH WATER SPRAY FROM MAXIMUM
DISTANCE UNTIL COOL, THEN MOVE CONTAINERS AWAY FROM FIRE AREA IF
WITHOUT RISK.
Unusual Fire/Explosion Hazard:CONTAINER MAY RUPTURE DUE TO HEAT OF
FIRE. NO PART OF CONTAINER SHOULD BE SUBJECT TO A TEMPERATURE
HIGHER THAN 52C (APPROXIMATELY 125F).
================== Accidental Release Measures ==================
Spill Release Procedures:IMMEDIATELY EVACUATE ALL PERSONNEL FROM DANGER
AREA. USE SELF-CONTAINED BREATHING APPARATUS WHERE NEEDED. SHUT OFF
LEAK IF WITHOUT RISK. VENTILATE AREA OF LEAK OR MOVE LEAKING
CONTAINER TO WELL-VENTIL ATED AREA. TEST AREA, ESPECIALLY CONFINED
AREAS, FOR SUFFICIENT OXYGEN CONTENT PRIOR TO PERMITTING RE-ENTRY
OF PERSONNEL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AND USE WITH ADEQUATE
VENTIALTION AT ALL TIMES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELECT IN ACCORDANCE WITH OSHA 29 CFR 1910.134.
RESPIRATORS SHALL BE ACCETABLE TO MSHA AND NIOSH.
Ventilation:LOCAL EXHAUST - PREFERRED. MECHANICAL (GENERAL) - ACCETABLE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:G3
Boiling Pt:=-108.3C, -163.F
Melt/Freeze Pt:=-111.7C, -169.F
Vapor Pres:GAS
Vapor Density:4.56 @ 70F
Spec Gravity:3.52 @ -109C
Evaporation Rate & Reference:GAS
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS, ODORLESS GAS AT NOTMAL TEMPERATURE AND
PRESSURE
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
XENON IS CHEMICALLY UNREACTIVE, BUT NOT COMPLETELY INERT.
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:SLOWLY RELEASE INTO ATMOSPHERE OUTDOORS. DISCARD
ANY PRODUCTS, RESIDUE, DISPOSAL CONTAINER OR LINER IN AN
ENVIRONMENTALLY ACCETABLE MANNER, IN FULL COMPLIANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:7500 TONER
CAGE:S0407
CAGE:S0407
============= Composition/Information on Ingredients =============
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 13%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:STYRENE ACRYLIC RESIN
Fraction by Wt: 85%
Ingred Name:DYE (PROPRIETARY)
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL RAT)>10 G/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN IRRITATION (RABBIT):MILDLY
IRRITATING. AMEST TEST RESULT:NEGATIVE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN:WASH THOROUGHLY WITH SOAP & WATER. EYE:TRY TO REMOVE OR
FLUSH OUT WITH EYE DROPS. IF UNSUCCESSFUL, GET MD. INHAL:MOVE TO
FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP) . INGEST:CALL MD
I MMEDIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, WATER SPRAY (FOG), DRY CHEMICAL OR CARBON
DIOXIDE MAY BE SUITABLE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:WILL NOT OCCUR.
================== Accidental Release Measures ==================
Spill Release Procedures:IF SPILLED, SWEEP UP OR PICK UP BY VACUUM
CLEANER. REMOVE WITH SOAP & COLD WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL DRY PLACE.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. DO NOT HANDLE WHERE
WIND BLOWS. FLYING POWDER MAY ENTER EYES. MINIMIZE INHALATION OF
DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NEEDED UNDER NORMAL USE CONDITION.
NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN
.
Ventilation:MECHANICAL (GENERAL):ADEQUATE VENTILATION.
Other Protective Equipment:NONE NEEDED.
Work Hygienic Practices:CLEANSE SKIN THOROUGHLY AFTER CONTACT, BEFORE
BREAKS AND MEALS, AND AT THE END OF WORK PERIOD.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:0.34 (H*2O=1)
Solubility in Water:NEGLIGIBLE; <0.1%
Appearance and Odor:BLACK POWDER, PRACTICALLY ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:CO AND OTHER DECOMPOSITION PRODUCTS IN
CASE OF INCOMPLETE COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:USED TONER SHOULD BE DISPOSED OF IN AN
ENVIRONMENTALLY SAFE MANNER AND IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. DO NOT INCINERATE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TEFLON PRIMER, GRAY, 850-321 (5/20/75)
CAGE:DO229
CAGE:18873
CAGE:DO229
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 5.0%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:UNIDENTIFIED COMPONENTS
Fraction by Wt: UNK
Ingred Name:WATER;CAS #7732-18-5
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: UNK
===================== Hazards Identification =====================
Effects of Overexposure:THERMAL DECOMPOSITION PRODUCTS MAY CAUSE
POLYMER FUME FEVER.INDCATRS:CHILLS,FEVER,& FLU-LIKE SYMPTMS
======================= First Aid Measures =======================
First Aid:INHALATION:MOVE TO FRESH AIR TO IMPROVE BREATHING;SKIN:WASH
WITH SOAP & WATER.REMOVE CONTAMINATED CLOTHING;EYES:FLUSH WITH
WATER FOR AT LEAST 15 MIN.CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:20-73F (C.C)
Lower Limits:1.3
Upper Limits:7.0
Extinguishing Media:CO*2, FOAM, DRY CHEM.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE UNPROTECTED PERSONS. ELIM IGNITION
SOURCES. STOP LEAK. H*2O SPRAY COOL CONT/DIVERT SPILL FROM
FIRE/HEAT. PROVIDE VENTILATION. ABSORB W COMMERCIAL
ABSORBENT,SHOVEL INTO METAL DRUMS:LG SPILL:DI KE W COMMERCIAL
ABSORBENT,PUMP INTO COVERED DRUMS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT,SPARKS, AND OPEN
Other Precautions:WASH THOROUGHLY AFTER HANDLING & BEFORE EATING OR
SMOKING;OBSERVE LABEL PRECAUTIONS;EXPLOSV REACTION MAY OCCUR ABOVE
796F W/FINELY DIVIDED AL/MG;REMOVE IGN SOURCE IF SOLVENTS ARE
PRESENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A CARTRIDGE TYPE RESP IF AIR CONTAMINANTS
CONTROL IS NOT FEASBLE
Ventilation:LOCAL EXHAUST TO MAINTN BELOW TLV.
Other Protective Equipment:USE APPROPRIATE INDUSTRIAL HYGIENE
PRACTICES.
Supplemental Safety and Health
MSDS FM MFR DATED:05/20/75;VAP PRESSURE/DENSITY NOTED OF PRINCIPAL
SOLVENT;AVOID PROLONGED SKIN CONTACT & BREATHING OF VAPOR DURING
SPILL CLEAN-UP PROCEDURES.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:212-232F
Vapor Pres:37
Vapor Density:3.1
Spec Gravity:1.421
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:APPRECIABLE
Appearance and Odor:GRAY-SEMI-VISCOUS LIQUID;MILD ODOR.
Percent Volatiles by Volume:68.1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, CORROSIVES
Stability Condition to Avoid:HEAT, IGNITION SOURCES
Hazardous Decomposition Products:CO,CO*2,HF,CF*4,COF*2,POSSBLY
PERFLUOROISOBUTYLENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:48760 PURGABLE AROMATIC KIT 602-N PT D
Kit Part:Y
CAGE:54968
CAGE:54968
============= Composition/Information on Ingredients =============
Ingred Name:O-DICHLOROBENZENE, 1,2-DICHLOROBENZENE (ORTHO)
CAS:95-50-1
RTECS #:CZ4500000
Other REC Limits:50 PPM
OSHA PEL:C 50 PPM
ACGIH TLV:S, 25PPM/50 STEL9394
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 500 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: FATAL. INHALATION: HARMFUL
& IRRITATION OF RESPIRATORY TRACT. EYES: IRRITATION. SKIN:
DERMATITIS, IRRITATION, & RAPID HARMFUL ABSORPTION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: LIVER & KIDNEY DAMAGE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: FLUSH W/LARGE VOLUMES
OF WATER. INHALATION: IMMEDIATELY REMOVE TO FRESH AIR. GIVE OXYGEN
IF BREATHING IS LABORED. IF BREATHING STOPS, GIVE ARTIFICIAL
RESPIRATION . INGESTION: NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. NEVER TRY TO MAKE AN UNCONSCIOUS PERSON VOMIT.
GIVE LARGE AMOUNTS OF WATER. GIVE SYRUP OF IPECAC. OBTAIN MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:150F
Lower Limits:2.2%
Upper Limits:9.2%
Extinguishing Media:WATER, CO2, DRY CHEMICAL, ALCOHOL FOAM
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS WHEN
FIGHTING A CHEMICAL FIRE.
Unusual Fire/Explosion Hazard:HYDROGEN CHLORIDE GAS MAY BE FORMED WHEN
THIS MATERIAL IS HEATED TO DECOMPOSITION.
================== Accidental Release Measures ==================
Spill Release Procedures:TAKE UP W/ABSORBENT MATERIAL. VENTILATE AREA.
ELIMINATE ALL IGNITION SOURCES. FLUSH AREA W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE ONLY IN WELL VENTILATED AREA.
STORE IN SEALED CONTAINER IN COOL, DRY LOCATION. KEEP AWAY FROM
IGNITION SOURCES.
Other Precautions:AVOID EYE & SKIN CONTACT. AVOID BREATHING VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/OSHA APPROVED RESPIRATORY PROTECTION.
Ventilation:ADEQUATE
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:178C
Melt/Freeze Pt:M.P/F.P Text:-18C
Vapor Pres:1.2
Vapor Density:1.5
Spec Gravity:1.305
Solubility in Water:0.2%
Appearance and Odor:CLEAR COLORLESS LIQUID, PLEASANT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, ALUMINUM & ITS ALLOYS
Stability Condition to Avoid:HEAT, LIGHT, & OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:HYDROGEN CHLORIDE GAS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PALCO 650 FLUX
CAGE:55708
CAGE:5S708
CAGE:55708
============= Composition/Information on Ingredients =============
Ingred Name:ZINC CHLORIDE; (ZINC CHLORIDE FUMES) (SARA 313) (CERCLA)
CAS:7646-85-7
RTECS #:ZH1400000
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3;2 STEL(FUME)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TIN (IV) CHLORIDE, (1:4); (TIN CHLORIDE)
CAS:7646-78-8
RTECS #:XP8750000
OSHA PEL:2 MG/M3 (SN)
ACGIH TLV:2 MG/M3 (SN)
Ingred Name:FLUORSPAR; (TOTAL FLUORIDE (F))
CAS:14542-23-5
OSHA PEL:N/K
ACGIH TLV:2.5 MG/M3 (MFR)
Ingred Name:SUPDAT:RESPECT TO FUME PLUME, AS WELL AS PRESENCE OF
CONTAMS IN ATMS (SUCH AS CHLORINATED HYDROCARBON VAPS FROM (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:CLEANING & DEGREASING ACTIVTIES). WHEN ROD & FLUX IS
CONSUMED, FUME & GAS DECOMP PRODS ARE DIFF IN PERCENT (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:& FORM FROM INGS. FUME & GAS DECOMP PRODS, NOT INGS
IN ROD, ARE IMPORTANT. DECOMP PRODS INCL THOSE (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:ORIGINATING FROM VOLATIZATION, RXN/OXIDATION OF INGS
PLUS THOSE FROM BASE METAL, FLUX, ETC. THESE (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:COMPONENTS ARE VIRTUALLY ALWAYS PRESENT AS COMPLEX
CMPDS & NOT AS METALS. REAS EXPECTED FUME CONSTITUENTS (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:COULD INCL FLUORIDES & OTHER COMPLEX OXIDES OF METALS
FOUND IN FILLER ALLOYS OF BASE METAL BEING WORKED (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:ON. GASEOUS RXN PRODS MAY INCL CARBON MONOXIDE &
CARBON DIOXIDE ACCORDING TO WELDING PROCESS BEING USED. (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:ONE REC WAY TO DETERMINE COMPOSITION & QTY OF FUMES
& GASES TO WHICH WORKERS ARE EXPOS IS TO TAKE AN AIR (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:SAMPLE INSIDE WELDER'S HELMET, IF WORN, OR IN
WORKER'S BRTHG ZONE. ANSI/AWS F1.1, AVAIL FROM AWS.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:D.C. 20402 FOR MORE DETAILS.
RTECS #:9999999ZZ
Ingred Name:EYE PROT:& FULL LGTH FCSHLD W/FILTER LENS. AS RULE OF
THUMB, START W/SHADE WHICH IS TOO DARK TO SEE WELD (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:ZONE. THEN GO TO NEXT LIGHTER SHADE WHICH GIVE
SUFFICIENT VIEW OF WELD ZONE. PROVIDE SCREENS & FLASH (ING 16)
RTECS #:9999999ZZ
RTECS #:9999999ZZ
Ingred Name:OTHER PROT EQUIP:TO PVNT INJURY FROM RADIA, SPKS & ELEC
SHOCK. SEE ANSI Z49.1. THIS MAY INCL ARM PROTECTORS, (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:APRONS, HATS, SHOULDER PROTECTION, AS WELL AS DARK
SUBSTANTIAL CLOTHING.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:FUMES & GASES CAN BE DANGEROUS TO YOUR
HEALTH. ACUTE:SHORT-TERM OVEREXPOSURE TO WELDING FUMES MAY RESULT
IN DISCOMFORT SUCH AS: DIZZINESS, NAUSEA, OR DRYNESS OR IRRITATION
OF NOSE, THROAT OR EYES. CHR ONIC:LONG-TERM OVEREXPOSURE MAY LEAD
TOSIDEROSIS (IRON DEPOSITS IN THE LUNGS) & IS BELIEVED BY SOME
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:INVESTIGATORS TO AFFECT PULMONARY
FUNCTION. ARC RAYS CAN INJURE EYES & BURN SKIN. ELECTRIC SHOCK CAN
KILL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:CALL FOR MEDICAL AID. EMPLOY FIRST AID TECHNIQUES RECOMMENDED
BY AMERCIAN RED CROSS. INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO
FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP) . EYES:I
MMEDIATELY FLUSH W/POTABLE WATER FOR A MINIMUM OF 15 MINUTES, SEEK
ASSISTANCE FROM MD . SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD
.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:WELDING ARC & SPARKS CAN IGNITE
COMBUSTIBLES. REFER TO ANSI Z49.1 FOR FIRE PREVENTION DURING
WELDING.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:TRAIN WELDER TO KEEP HIS HEAD OUT OF
FUMES. TRAIN WELDER NOT TO TOUCH LIVE ELEC PARTS & TO INSULATE
HIMSELF FROM WORK & GROUND.
Other Precautions:READ & UNDERSTAND MFR'S INSTRUCTIONS & PREC LBL ON
THIS PROD. SEE ANSI Z49.1, SFTY IN WELDING & CUTTING, PUBLISHED BY
AWS, P.O. BOX 351040, MIAMI, FL 33135 & OSHA PUBLICATION 2206 (29
CFR 1910), U.S. GOVT PRINTING OFC, WASHINGTON, (ING 13)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRABLE FUME
RESPIRATOR OR AIR SUPPLIED RESPIRATOR WHEN WELDING IN CONFINED
SPACE OR WHERE LOCAL EXHAUST OR VENTILATION DOES NOT KEEP EXPOSURE
BELOW TLV.
Ventilation:USE ENOUGH VENT, LOC EXHST AT ARC, OR BOTH, TO KEEP FUMES &
GASES BELOW TLV'S IN WORKER'S BRTHG ZONE & GEN AREA.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . WEAR HEAD, HAND & BODY PROT WHICH HELP(ING
17)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HAZ DECOMP PROD:PROCESS, FLUX, PROCS & ALLOY USED. OTHER CNDTNS WHICH
ALSO INFLUENCE COMPOSITION & QTY OF FUMES & GASES TO WHICH WORKERS
MAY BE EXPOS INCL:COATINGS ON METAL BEING WELDED (SUCH AS PAINT ,
PLATING/GALVANIZATION), NUMBER OF WELDS & VOL OF WORK AREA, QUALITY
& AMT OF VENT, POSITION OF WELDER'S HEAD W/(ING 4)
================== Physical/Chemical Properties ==================
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WELDING FUMES CANNOT BE CLASSIFIED
SIMPLY. COMPOSITION & QTY OF BOTH ARE DEPENDENT UPON METAL BEING
WELDED, (SUPP DATA)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HI-BILD CHLORINATED RUBBER ENAMEL B63 W 1 PURE WHITE
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:CARBON TETRACHLORIDE (SARA III)
CAS:56-23-5
RTECS #:FG4900000
Fraction by Wt: 1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 PPM Z-2
ACGIH TLV:S,5PPM/10 STEL,A3 94
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ozone Depleting Chemical:1
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 11%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:NAPHTHA, LIGHT AROMATIC
CAS:64742-95-6
Fraction by Wt: 21%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM 9091
Ingred Name:METHYL ISOBUTYL KETONE (SARA III)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:50 PPM/75 STEL; 9394
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL N-AMYL KETONE
CAS:110-43-0
RTECS #:MJ5075000
Fraction by Wt: 12%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9394
Ingred Name:TALC (CONTAINING ASBESTOS)
CAS:14807-96-6
RTECS #:MW2700000
Fraction by Wt: 3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:0.2 FIBER/CC,A1;9394
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9394
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:UNKNOWN IARC:UNKNOWN OSHA:NO
Health Hazards Acute and Chronic:ACUTE-EYES: MAY CAUSE MODERATE
IRRITATION, REDNESS AND TEARING. SKIN: MAY CAUSE SLIGHT IRRITATION.
MAY CAUSE SEVERE IRRITATION WITH REPEATED OR PROLONGED CONTACT.
INHALATION: MAY CAUSE IRRITATION OF N ASAL AND RESPIRATORY
PASSAGES. MAY CAUSE NERVOUS SYSTEM DEPRESSION.
Effects of Overexposure:HEADACHE, DIZZINESS, NAUSEA AND LOSS OF
COORDITATION ARE INDICATIONS OF EXCESSIVE EXPOSURE TO VAPORS OR
SPRAY MISTS. REDNESS AND ITCHING OR BURNING SENSATION MAY INDICATE
EYE OR EXCESSIVE SKIN EXPOSUR E.
Medical Cond Aggravated by Exposure:LIVER OR KIDNEY DISEASE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH EYES WITH LARGE AMOUNTS OF WATER FOR 15 MINUTES.
GET MEDICAL ATTENTION. SKIN: WASH AFFECTED AREA THOROUGHLY WITH
SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. INHALATION: REMOVE
FROM EXPOS URE. RESTORE BREATHING. KEEP WARM AND QUIET. INGESTION:
GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:70.0F,21.1C
Lower Limits:0.7
Upper Limits:7.0
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT SCBA. WATER SPRAY
MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE PERFERRED.
WATER MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:WATER COOL CLOSED CONTAINERS TO PREVENT
PRESSURE BUILDUP/AUTOIGNITION/EXPLOSION WHEN EXPOSED TO HEAT.
OVEREXPOSURE TO DECOMPOSITION PRODUCTS MAY CAUSE HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:TRANSFER ONLY TO APPROVED CONTAINERS
WITH COMPLETE AND APPROPRIATE LABELING. KEEP AWAY FROM HEAT, SPARKS
AND OPEN FLAME. KEEP AREA VENTILATED.
Other Precautions:PROTECT AGAINST DUST WHICH MAY BE GENERATED BY
SANDING OR ABRADING THE DRIED FILM. KEEP AWAY FROM HEAT & OPEN
FLAME. KEEP CONTAINER CLOSED WHEN NOT IN USE. DO NOT TAKE
INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, WEAR A PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESPIRATORY APPROVED BY NIOSH/MSHA.
Ventilation:PROVIDE LOCAL EXHAUST VENTILATION TO KEEP APPLICABLE
EXPOSURE LIMITS.
Other Protective Equipment:USE BARRIER CREAM ON EXPOSED SKIN IS
RECOMMENDED.
Work Hygienic Practices:WASH HANDS AFTER EACH USE.
Supplemental Safety and Health
WT/GAL: 9.95 LBS.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:237F,114C
Vapor Density:>1
Spec Gravity:1.05
Evaporation Rate & Reference:SLOWER THAN ETHER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, HOT SURFACES.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE, HYDROGEN CHLORIDE, OXIDES OF METAL.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE, &
LOCAL REGULATIONS. WASTE MAY BE HAZARDOUS AS DEFINED UNDER RCRA.
INCINERATE IN APPROVED FACILITY. DO NOT INCINERATE CLOSED
CONTAINER.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DIBROM CONCENTRATE, PRODUCT NO:64576
CAGE:GO545
CAGE:0LD98
CAGE:GO545
============= Composition/Information on Ingredients =============
Ingred Name:DIBROM CONCENTRATE
CAS:300-76-5
RTECS #:TB9450000
Fraction by Wt: 100.0%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:NALED
CAS:300-76-5
RTECS #:TB9450000
Fraction by Wt: 85.0%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:INERT INGREDIENTS & IMPURITIES IN TECHNICAL GRADE MATERIALS
(TRADE SECRETS).
Fraction by Wt: 15%
Other REC Limits:NONE RECOMMENDED
Ingred Name:RELATED COMPOUNDS
Fraction by Wt: <8.5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:PHOSPHORIC ACID, 2,2-DICHLOROETHENYL DIMETHYL ESTER
CAS:62-73-7
RTECS #:TC3500000
Fraction by Wt: 1.5%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:METHYL BROMIDE (SARA III)
CAS:74-83-9
RTECS #:PA4900000
Fraction by Wt: <1.9%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S, C 20 PPM
ACGIH TLV:S, 5 PPM; 9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:CARBON TETRACHLORIDE (SARA III)
CAS:56-23-5
RTECS #:FG4900000
Fraction by Wt: 0.5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 PPM; Z-2
ACGIH TLV:S, 5 PPM; A3; 9394
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ozone Depleting Chemical:1
Ingred Name:DIMETHYL BENZENE/XYLENE (SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: <0.2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TRIMETHYLBENZENE
CAS:25551-13-7
RTECS #:DC3220000
Fraction by Wt: <3.4%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9394
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT ESTABLISHED FOR THIS MATL, SEE SUPPL
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:HEALTH EFFECTS CONSISTENT
W/ORGANOPHOSPHATE POISONING.ABSORBED THRU EYE/SKIN.EYE:SEV
IRRIT,PERM EYE DAMAGE,BLINDNESS.SKIN:CORR TO SKIN & MUC
MEMB.PROLONG CONTACT INJURY,DEATH TO UNDERLYING TISSU
E.INGEST:TOXIC.CORR TO MUC MEM.INHAL:CORR TO MUC MEM.HIGHLY
TOXIC.CHRONIC:DECREASE IN CHOLINESTERASE ACTIVITY.
Explanation of Carcinogenicity:PER MSDS:CONTAIN SMAL AMTS OF CHEM
CONSIDERED TO BE PROBABLE HUMAN CANCI BY EPA BUT ANIMAL STUDIES
DON'T INDICATE.
Effects of Overexposure:EYE:PAIN,TEARS,SWELLING,REDNESS,BLURRED
VISION.HEAD,DIZZ,WEKNESS,CONSTRICTION OF PUPIL,BLURRED/DARK
VISION,EXCESSIVE SALIVATION/NASAL DISCHZRGE,PROFUSE
SWEAT,CRAMPS,NAU,DIA,VOMIT.SKIN:PAIN,FEELING OF
HEAT,DISCOLORATION,SWELLING,BLISTERING,ITCHING.INGEST:NAU,VOMIT,DIA
.INHAL:SORE THROAT,COUGH,BRONCHITIS,PULM EDEMA.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MFG.
======================= First Aid Measures =======================
First Aid:EYE:IMMED HOLD EYELIDS OPEN & FLUSH W/PLENTY OF FRESH
WATER.REMOVE CONTACT LENSES IF WORN.GET MED ATTN IMMED. SKIN:REMOVE
CONTAMIN CLOTH.WASH THOROUGHLY W/SOAP & WATER.SEE DR
IMMED.INGEST:DRINK 1 OR 2 GLASSES OF WATER OR MILK.INDUCE VOMIT BY
TOUCHING BACK OF THROAT W/FINGER.CALL DR/POI CNTRL CNTR/EMERG CNTR
BEFORE INDUCING VOMIT.TAKE TO NEAREST EMERG CTNR.INHAL:MOVE TO
FRESH AIR.(SEE SUPPLEMTN).
===================== Fire Fighting Measures =====================
Flash Point:116F,47C
Lower Limits:1
Upper Limits:7
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:AVOID BREATH SMOKE/MIST & PERSONNEL/EQPMT
CONTACT W/FALLOUT/RUNOFF.MIN AMT OF WATER USED FOR
FIREFIGHTING.DON'T ENTER ENCLSD AREA W/O FULL PROT EQPMT.DECONTAMIN
Unusual Fire/Explosion Hazard:LIQ EVAPORATES,FORMS VAP WHICH CATCHES
FIRE & BURN W/EXPLO VIOLENCE.INVISIBLE VAP SPREADS EASILY.FIRE HAZ
GREATER AS LIQ TEMP RISES >85F.COMBUST PROD TOXIC.
================== Accidental Release Measures ==================
Spill Release Procedures:FOR HELP W/ANY SPILL/LEAK/FIRE/EXPO OF MATL
CALL DAY/NIGHT 800-892-0099.REMOVE IGN SOURCES.CLEANUP IMMED.COVER
SPILL W/GENEROUS AMT OF OIL DRY/CATLITTER/CLAY/RAGS/OTHER
ABSORBENT.MIX WELL W/STIFF BRRO M.SWEEPUP INTO DISPO CNTNR.SCRUB
ARE W/DETER/WATER
Neutralizing Agent:NONE SPECIFIED BY MFG.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN ORIGINAL CNTNR.DO NOT
STORE/TRANSP NEAR FOOD/FEED.DO NOT CONTAMIN FOOD/FEED,PUT CONCEN
INTO FOOD/DRINK CNTNRS.DO NOT DILUTE IN FOOD/DRINK CNTR
Other Precautions:DON'T USE/STORE NEAR FLAME/SPARKS/HOT SURFACES.USE
ONLY IN WELL VENTI AREA.KEEP CNTNR CLSD.DON'T WELD/HEAT/DRILL
CNTNR.REPLACE CAP/BUNG.EMPTIED CNTNR STILL CONTAINS HAZ/EXPLO
VAP/LIQ.DON'T APPLY DIREC TLY TO WATER EXCEPT WHEN USED OVER WATER
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROVED RESPIRATORY PROTECTION WHEN
WORKING W/THIS MATERIAL.AN AIR-SUPPLING RESP IS RECOMMENDED.
Ventilation:MUST BE DEMONSTRATED TO BE ADEQUATE TO KEEP AIRBORNE CONCEN
OF MATRL BELOW RECOMMENDED EXPOUSRE STDS PRIOR TO USING MATL
Other Protective Equipment:IMPERVIOUS PROTECTIVE
CLOTHING,APRON,OVERSHOES,COMPLETE FACIAL PROTECTION.
Work Hygienic Practices:WASH HANDS AFTER HANDLING.DISCARD CONTAM
NONWATERPROOF SHOES/BOOTS.WASH CONTAM CLOTHING PRIOR TO REUSE.
Supplemental Safety and Health
LD50,ORAL,RAT FOR SIMILAR PRODUCT (NALED TECHNICAL)=191MG/KG MALE,
92MG/KG FEMALE. 1STAID:GIVE ART RESP IF NOT
BREATH.PHYSICIAN:CONTAINS CHOLINESTERASE INHIBITOR.IF SIGNS OF
INHIBITION APPEARS ATROPIN E SULFATE IS ANTIDOTAL.2-PAM(PROTOPAM)
IS ANTIDOTAL & MAY BE USED IN CONJUCTION W/ATROPINE BUT SHOULD NOT
BE USED ALONE.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:320F,160C
Vapor Pres:10MM @100F
Solubility in Water:SLIGHTLY SOLUBLE.
Appearance and Odor:LIGHT STRAW-COLORED LIQUID WITH SLIGHTLY PUNGENT
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
IRON OR ALKALINE MEDIA. CORROSIVE TO ALUMINUM & MAGNESIUM. HYDROLYZES
SLOWLY UNDER NEUTRAL OR ACID CONDITIONS.
Stability Condition to Avoid:MAY BE PHOTOCHEMICALLY REACTIVE.
Hazardous Decomposition Products:CARBON DIOXIDE,WATER VAP,OXIDES OF
PHOSPHORUS.TOXIC COMPDS OF CHLORINE & BROMINE.CARBON MONOXIDE FROM
INCOMPLETE COMBUST
==================== Disposal Considerations ====================
Waste Disposal Methods:NONE SPECIFIED BY MFG. HOWEVER DISPOSE OF IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.TOXIC TO
WILDLIFE & AQUATIC ORGANISMS,HIGHLY TOXIC TO BEES EXPO TO DIRECT
TRETMENT/RESIDUE ON BLOOMING CROPS/WEEDS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:NICKEL CADMIUM SEALED CELL BATTERY
CAGE:67237
CAGE:67237
============= Composition/Information on Ingredients =============
Ingred Name:CADMIUM (SARA 313) (CERCLA)
CAS:7440-43-9
RTECS #:EU9800000
Fraction by Wt: <17%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 MG/M3 DUST; Z-2
ACGIH TLV:0.01 MG/M3 DUST;9495
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:CADMIUM HYDROXIDE
CAS:21041-95-2
Fraction by Wt: <17%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.05 MG CD/M3
ACGIH TLV:0.05 MG CD/M3
Ingred Name:CADMIUM OXIDE (SARA 302/313) (CERCLA)
CAS:1306-19-0
RTECS #:EV1925000
Fraction by Wt: <17%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 MG (CD)/M3 DUST
ACGIH TLV:0.01 MG(CD)/M3; 9495
Ingred Name:NICKEL (SARA 313) (CERCLA)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: <19%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9495
Ingred Name:NICKEL HYDROXIDE (SARA 313) (CERCLA)
CAS:12054-48-7
RTECS #:QR7040000
Fraction by Wt: <19%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG(NI)/M3
ACGIH TLV:0.1 MG(NI)/M3; 9495
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:NICKEL OXIDE
CAS:1313-99-1
RTECS #:QR8400000
Fraction by Wt: <19%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3 AS NI
ACGIH TLV:1 MG/M3 AS NI
Ingred Name:POTASSIUM HYDROXIDE (CERCLA)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 8%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:COBALT (SARA 313)
CAS:7440-48-4
RTECS #:GF8750000
Fraction by Wt: 1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.02 MG/M3; A3; 9495
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:IN CASE OF FIRE OR CELL RUPTURE,
ELECTROLYTE CAN CAUSE SKIN AND EYE IRRITTAION/BURNS ON CONTACT.
INGESTION OF ELECTROLYTE CAUSES TISSUE AND GI TRACT DAMAGE. NICKEL
COMPOUNDS MAY CAUSE NICKEL ITCH/ECZE MA ON CONTACT; INTESTINAL
DISORDERS IF INGESTED. INHALATION OF METAL FUMES MAY CAUSE
IRRITATION/LUNG DAMAGE.
Explanation of Carcinogenicity:CONTAINS CADMIUM AND NICKEL AND THEIR
COMPOUNDS WHICH ARE LISTED BY NTP AND IARC AND REGULATED BY OSHA AS
A CARCINOGEN.
Effects of Overexposure:EYES-REDNESS, TEEARING, PAIN, BLURRED VISION.
INHALED: COUGHING, SNEEZING, WHEEZING, SHORTNESS OF BREATH, CHILLS,
WEAKNESS, COUGHING, CHEST PAINS. SKIN: REDNESS, ITCHING,
DISCOMFORT. INGESTED: NAUSEA, VOMITING, DIARRHEA, ABDOMINAL
CRAMPS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
DLA-HMIS: RESPIRATORY SYSTEM DISORDERS, PROSTATE DISORDERS, LIVER
AND KIDNEY DISORDERS.
======================= First Aid Measures =======================
First Aid:EYES-FLUSH WITH LOTS OF WATER. GET IMMEDIATE MEDICAL
ATTENTION. SKIN-REMOVE CONTAMIANTED CLOTHES. FLUSH AFFECTED AREAS
WITH LOTS OF WATER FOR AT LEAST 15 MINUTES. WASH WITH SOAP & WATER.
INGESTED-DO N OT INDUCE VOMITING! IF CONSCIOUS, GIVE SEVERAL
GLASSES WATER. GET IMMEDIATE MEDICAL ATTENTION. INHALED-REMOVE TO
FRESH AIR. GIVE OXYGEN OR ARTIFICIAL RESPIRATION IF NEEDED. GET
IMMEDICAT MEDICAL ATTN.
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, SAND.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE CLOTHING IF INVOLVED IN A FIRE.
Unusual Fire/Explosion Hazard:ELECTROLYTE SOLUTION IS CORROSIVE TO
TISSUE; REACTS VIOLENTLY WITH MANY ORGANIC CHEMICALS & ZINC, TIN,
ALUMINUM & OTHER ACTIVE METALS. CADMIUM FUMES RELEASED.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH WITH WATER AND NEUTRALIZE WITH DILUTE
CITRIC ACID.
Neutralizing Agent:DILUTE CITRIC ACID.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY AREA. DO NOT
SHORT CIRCUIT. DO NOT BREAK OPEN CELL. DO NOT ALLOW AN EXPOSED
FLAME OR SPARK TO COME NEAR CELLS.
Other Precautions:THESE CELLS AND THE BATTERIES CONSTRUCTED FORM THEM
MAY BE HIGHLY CHARGED AND ARE CAPABLE OF HIGH ENERGY DISCHARGE.
CARE SHOULD BE TAKEN TO HANDLE CELLS TO AVOID SHORTING OR MISUSE
THAT MAY CAUSE ELEC TRICAL/CHEMICAL/HEAT ENERGY RELEASE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. IF EMERGENCY OCCURS; USE
NIOSH/MSHA APPROVED RESPIRATOR WITH DUST CARTRIDGE. USE IN
ACCORDANCE WITH 29 CFR 1910.134 AND THE RESPIRATOR MANUFACTURER'S
RECOMMENDATIONS.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION OR LOCAL EXHAUST TO
MAINTAIN EXPOSURE BELOW PEL/TLV.
Other Protective Equipment:WEAR COVERALLS WHEN HANDLING. HMIS: EYE WASH
STATION & SAFETY SHOWER AVAILABLE.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
MSDS RECEIVED FROM DLA DEPOT FOR TECH SUPPORT. DLA-HMIS INSTRUCTED TO
INPUT IMMEIDATELY.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.17-1.25
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BATTERY.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALUMINUM, TIN, ZINC & OTHER ACTIVE METALS; CHLORINATED & AROMATIC
HYDROCARBONS, NITROCARBONS, HALOCARBONS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NICKEL OXIDE, CADMIUM, CADMIUM OXIDE
AND POTASSIUM HYDROXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:THE STORAGE BATTERY IS A HAZARDOUS WASTE UNDER
RCRA. IT MAY BE RETURNED TO SAFT FOR RECYCLING. DISPOSE OF IN
ACCORDANCE WITH FEDERAL, STATE, AND LOCAL LAWS. BATTERY IS A TCLP
TOXIC. BATTERY & ELECTROL YTE ARE CORROSIVE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ACRIGLO
CAGE:0C4T4
CAGE:0C4T4
============= Composition/Information on Ingredients =============
Ingred Name:MERCURY, (ACETATO) PHENYL; (PHENYL MERCURIC ACETATE)
CAS:62-38-4
RTECS #:OV6475000
ACGIH TLV:0.1 MG/M3 (MFR)
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:VAPOR ODORS MAY CAUSE
IRRITATION, NAUSEA, HEADACHES & DIZZINESS. EYE:MATERIAL IS SLIGHTLY
ALKALINE & MAY CAUSE MINOR IRRITATION, REDNESS & TEARING.
SKIN:MATERIAL IS SLIGHTLY ALKALINE & MAY CAUSE MINOR IRRITATION.
INGEST:CAN CAUSE NAUSEA, VOMITING, DIARRHEA & GI IRRITATION.
CHRONIC:NONE (SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:RECOGNIZED.THIS PROD CONTAINS CHEM(S)
KNOWN TO STATE OF CALIFORNIA TO CAUSE CANCER OR BIRTH DEFECTS OR
OTHER REPROD HARM.NOTE:MERCURY COMPOUNDS APPEAR ON THE NAVY LISTING
OF OCCUP REPRO HAZ. SEEK CONSULTATION FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZ INFO & SAFE HNDL & EXPOS
RECOMMENDATIONS .
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:CLEAN W/PLENTY OF WATER FOR AT LEAST 15 MIN. SKIN:CLEAN
W/SOAP & WATER. INHAL:MOVE AFFECTED PERSON TO FRESH AIR. APPLY ARTF
RESP IF NECESSARY. SEE MD IMMED. INGEST:DRINK WATER TO DILUTE. DO
NOT IN DUCE VOMITING. CALL MD.
===================== Fire Fighting Measures =====================
Flash Point:225F,107C
Lower Limits:0.62%
Upper Limits:4.24%
Extinguishing Media:WATER SPRAY, FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:KEEP AWAY FROM HEAT. CONTAINERS MAY
EXPLODE WHEN EXPOSED TO EXTEME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN SPILLS IMMEDIATELY WITH ABSORBANT SUCH
AS CLAY OR DIATOMACEOUS SILICA.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE. DO NOT STORE OR HANDLE NEAR HEAT, FLAMES & STRONG OXIDANTS.
STORE IN COOL, WELL-VENTILATED AREA.
Other Precautions:ROTATE STOCK, USE OLDER MATERIALS FIRST. INSPECT FOR
LEAKS IN ALL CONTAINERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR IF TLV IS
EXCEEDED.
Ventilation:PROVIDE SUFFICIENT VENTILATION TO MAINTAIN EXPOSURE LEVEL
BELOW TLV/PEL.
Other Protective Equipment:USE EYE WASH & SAFETY SHOWER. USE IMPERVIOUS
CLOTHING OR CHANGE CONTAMINATED CLOTHING IMMEDIATELY.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:0.22 @ 20C
Spec Gravity:1.2
Solubility in Water:YES
Appearance and Odor:LIQUID, MILD CHARACTERISTIC ODOR OF LATEX RESIN &
COMBINED ADDITIVES.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CO*2 &/OR CO, AND UNIDENTIFIED ORGANIC
COMPOUNDS MAY BE FORMED DURING COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ALL WASTE I/A/W FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:2500, PRO-HIDE PLUS LATEX FLAT PRO WHITE
CAGE:77359
CAGE:77359
============= Composition/Information on Ingredients =============
Ingred Name:ING 9:MAY NOT BE DIRECTLY RELEVANT TO WORKPLACE WHERE OCCUP
EXPOS LIM ARE OBSERVED. @ TLV OF TIO*2 MFR CONCLUDES(ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:THAT THERE IS NO SIGNIFICANT HAZARD FOR MAN.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:THE PRINCIPAL TOX EFTS OF ETHYLENE GLYCOL,
WHEN SWALLOWED, ARE KIDNEY DAM & METABOLIC ACIDOSIS. (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:ETHANOL IS ANTIDOTAL, & ITS EARLY ADMIN MAY BLOCK
FORM OF NEPHROTOXIC METABOLITES OF ETHYLENE GLYCOL IN (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:LIVER. ETHANOL SHOULD BE GIVEN BY IV, AS A 5% SOLN
IN SODIUM BICARBONATE, @ RATE OF 10 ML ETHANOL PER HR.(ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:A DESIRED THERAP LEVEL OF ETHANOL IN BLOOD IS 100
MG/DL. HEMODIALYSIS MAY BE REQD. PULM EDEMA W/HYPOXEMIA(ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:HAS OCCURRED IN A NUMBER OF PATIENTS FOLLOWING
POISONING W/ETHYLENE GLYCOL. MECHANISM OF PRODUCTION HAS (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:NOT DETERMINED, BUT IT APPEARS TO BE NON-CARDIOGENIC
IN ORIGIN IN SEVERAL CASES. RESP SUPPORT W/MECH VENT(ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:& POSITIVE END-EXPIRATORY PRESSURE MAY BE REQUIRED.
RTECS #:9999999ZZ
Ingred Name:VENT: BELOW LOWEST EXPOSURE LIMITS STATED.
RTECS #:9999999ZZ
Ingred Name:ETHYLENE GLYCOL. VP: 1@20C
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: <5%
OSHA PEL:50 PPM, C
ACGIH TLV:50 PPM, VAP/MIST, C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 5%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:VOLATILE ORGANIC COMPOUNDS; 1.1 LB/GAL LESS WATER & NPRS
132
RTECS #:9999999VO
Ingred Name:VOLATILE ORGANIC COMPOUNDS: 1.2 LB/GAL SOLIDS (144 G/L
SOLIDS) CALCULATED
RTECS #:9999999VO
Ingred Name:SUPP DATA: IN HUMANS, IT IS CONSIDERED AN ANIMAL TERATOGEN.
DRY TITANIUM DIOXIDE IN A 24-MONTH INHAL STUDY W/RATS(ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:REVEALED A SIGNIFICANT INCR IN BENIGN & MALIGNANT
LUNG TUMORS IN GROUP EXPOS TO 250 MG/M3 RESPIRABLE TI02 (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:DUST. @ LOWER EXPOS LEVELS, THIS SIGNIFICANT EFT WAS
NOT OBSERVED. NORM CLEARANCE MECHANISMS OF LUNGS MAY (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:HAVE BEEN OVERWHELMED @ 250 MG/M3 EXPOS LEVEL, & MAY
HAVE CONTRIBUTE TO OCCURRENCE OF CARCIN. THESE RSLTS (ING 10)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INGEST:SWALLOWING OF ETHYLENE
GLYCOL MAY CAUSE ABDOM DISCOMFORT/PAIN/DIZZ/MALAISE, LUMBAR PAIN,
OLIGURIA, UREMIA, & CNS DEPRESS. SEV KIDNEY DAM FOLLOWS SWALLOWING
OF LG VOL OF ETHYLENE GLYCOL. M AY BE FATAL. INHAL:MAY CAUSE RESP
IRRIT. EYE:MAY CAUSE IRRIT. SKIN:MAY CAUSE DEFAT & IRRIT. RPTD
EXPOS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:CRYSTALLINE SILICA: IARC GROUP 2A, NTP
ANCITICAPATED TO BE A CARCINOGEN.
Effects of Overexposure:HLTH HAZ:TO CRYSTALLINE SILICA MAY CAUSE
PNEUMOCONIOSIS, A PROGRESSIVELY DISABLING LUNG DISEASE. OSHA
PERMISSIBLE EXPOS LIM FOR AMBIENT DUST CNTNG CRYSTALLINE SILICA MAY
BE CALCULATED FROM FORMULAS PR OVIDED IN TABLE Z-3"MINERAL
DUSTS"-29 CFR 1910.1000. ETHYLENE GLYCOL HAS BEEN SHOWN TO PRDCE
DOSE-RELATED (SUPP DATA)
Medical Cond Aggravated by Exposure:PREEXISTING RESPIRATORY CONDITIONS
MAY BE AGGRAVATE BY EXPOSURE TO CRYSTALLINE SILICA.
======================= First Aid Measures =======================
First Aid:INGEST: IMMED GIVE 1-2 GLASSES OF H2O & CALL POIS CTL CTR,
HOSP EMER ROOM/PHYS FOR WAY TO INDUCE VOMIT. (NEVER GIVE ANYTHING
BY MOUTH TO AN UNCON PERSON). INHAL: REMOVE TO FRESH AIR. EYE:
FLUSH W/LG A MTS OF H2O, LIFT LIDS OCCAS. CONTINUE FOR @ LST 15
MIN. GET MED ATTN. SKIN: REMOVE CONTAMD CLTHG. WASH AFFECTED AREA
W/SOAP/H2O. OBTAIN MED ATTN IF IRRIT PERSISTS. NOTES TO PHYS: (ING
12)
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>200F,>93C
Extinguishing Media:USE NFPA CLASS B FIRE EXTING (CO2 ALL PURPOSE DRY
CHEM/ALCOHOL FOAM) DESIGNED TO EXTING FLAM LIQ FIRES. (SUPP DATA)
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP. H2O
MAY BE INEFTIVE, BUT MAY BE USED TO COOL EXPOS CONTR TO PVNT PRESS
BUILD-UP & POSS AUTOIGNIT/ (SUPP DATA)
Unusual Fire/Explosion Hazard:DURING EMER CNDNTS, OVEREXP TO DECOMP
PROD MAY CAUSE HLTH HAZ. SYMP MAY NOT BE IMMED APPARENT. OBTAIN
MEDICAL ATTENTION.
================== Accidental Release Measures ==================
Spill Release Procedures:CONFINE IN SMALL AREA; USE ABSORBENT TO CLEAN
UP. PLACE IN CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT FROM FREEZING OR EXTREMELY
HIGH TEMPERATURES.
Other Precautions:DO NOT TAKE INTERNALLY. CLOSE CONTAINER AFTER EACH
USE. DO NOT BREATHE SANDING DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF APPLIED BY SPRAYING, USE AN APPROP, PROPERLY
FITTED NIOSH/MSHA APPROVD RESPIRATOR TO REMOVE SPRAY MIST. REFER TO
OSHA 29 CFR 1910.134 "RESPIRATORY PROTECTION".
Ventilation:PROVIDE GEN DILUTION & LOC EXHAUST VENT IN SUFFICIENT VOL &
PATTERN TO MAINTAIN CONC OF HAZ SUBSTANCES LISTED (ING 19)
Other Protective Equipment:NOT LIKELY TO BE NEEDED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXTING MEDIA:POLYMER FOAM IS PREFERRED FOR LG FIRES. FIRE FIGHT PROC:
EXPLO WHEN EXPOS TO EXTREME HEAT. IF H2O IS USED, FOG NOZZ ARE
PREF. EFTS OF OVEREXP: BIRTH DEFECTS IN RATS & MICE WHEN GIVEN BY M
OUTH @ HIGH CONC. BECAUSE THERE IS NOT CURRENTLY AVAIL INFO TO
SUGGEST THAT ETHYLENE GLYCOL CAUSES BIRTH DEFECTS(ING 6)
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>193F,>89C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:1.306
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:68
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT AND SOURCES OF
IGNITION.
Hazardous Decomposition Products:BURNING, INCLUDING WHEN HEATED BY
WELDING OR CUTTING, WILL PRODUCE SMOKE, CO & CO2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL LAWS. AS PRODUCED, PRODUCT IS NOT CLASSIFIED AS HAZARDOUS
WASTE UNDER RCRA.
| 1 | eyes_protection_mandatory |
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.