text
stringlengths 595
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:F2180S TRANS-NONACHLOR 100 UG/ML IN METHANOL
CAGE:84898
CAGE:84898
CAGE:8Y898
============= Composition/Information on Ingredients =============
Ingred Name:TRANS-NONACHLOR
CAS:39765-80-5
RTECS #:PC0950000
Ingred Name:METHANOL (METHYL ALCOHOL), COLUMBIAN SPIRITS *94-4*
CAS:67-56-1
RTECS #:PC1400000
Other REC Limits:200 PPM
OSHA PEL:260 MG/CUM
ACGIH TLV:262 MG/CUM (SKIN)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 5628 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE FATAL IF ABSORBED THROUGH THE
SKIN, INHALED/SWALLOWED. EYES: VAPORS/DUST CAN CAUSE INJURY.
INGESTION MAY CAUSE BLINDNESS. EXPOSURE CAN CAUSE LIVER/KIDNEY
DAMAGE & CARDIOVASCULAR SYSTEM INJURY.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:GASTROINTESTINAL DISTURBANCES, CONVULSIONS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH CONTINUOUSLY W/WATER FOR 15-20 MINS. SKIN: FLUSH
W/WATER FOR 15-20 MINS. IF NO BURNS HAVE OCCURED, USE SOAP & WATER.
INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN/CPR IF NECESSARY.
OBTAIN M EDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:51.8F
Lower Limits:6.7
Upper Limits:36
Extinguishing Media:CO2/DRY CHEMICAL POWDER. DO NOT USE WATER.
Unusual Fire/Explosion Hazard:THIS IS A FLAMMABLE CHEMICAL.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR APPROPRIATE EQUIPMENT.
VENTILATE AREA. ABSORB ON VERMICULITE/SIMILAR MATERIAL. SWEEP UP &
PLACE IN AN APPROPRIATE CONTAINER & HOLD FOR DISPOSAL. WASH
CONTAMINATED SURFACES TO REMOV E ANY RESIDUES.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP TIGHTLY CLOSED IN A COOL DRY
PLACE. STORE ONLY W/COMPATIBLE CHEMICALS.
Other Precautions:AVOID CONTACT W/SKIN, EYES & CLOTHING. FOR LABORATORY
USE ONLY. MAY NOT BE USED AS DRUGS, COSMETICS,
AGRICULTURAL/PESTICIDAL PRODUCTS, FOOD ADDITIVES/HOUSEHOLD
CHEMICALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE APPROPRIATE OSHA/MSHA APPROVED SAFETY
EQUIPMENT.
Ventilation:CHEMICAL SHOULD BE HANDLED ONLY IN A HOOD.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE.
Supplemental Safety and Health
INFORMATION FOR THIS MSDS IS FOR METHYL ALCOHOL.
%/
%/
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:148.28F
Melt/Freeze Pt:M.P/F.P Text:-144.4F
Vapor Pres:97
Vapor Density:1.11
Solubility in Water:MISCIBLE
Appearance and Odor:COLORLESS LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, ACID HALIDES & ANHYDRIDES, STRONG OXIDIZING AGENTS,
STRONG REDUCING AGENTS, ACTIVE METALS; SODIUM
Stability Condition to Avoid:MOISTURE
Hazardous Decomposition Products:TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN A CHEMICALS INCINERATOR EQUIPPED W/AN
AFTER BURNER & SCRUBBER IAW/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
Product ID:875 1158 EKTACOLOR PRIME DEVELOPER REPLENIS
Kit Part:Y
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 95-100%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM CARBONATE
CAS:584-08-7
RTECS #:TS7750000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHANOL, 2,2',2"-NITRILOTRI-; (TRIETHANOLAMINE)
CAS:102-71-6
RTECS #:KL9275000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:5 MG/M3
Ingred
Name:4-(N-ETHYL-N-2-METHANESULFONYLAMINOETHYL)-2-METHYLPHENYLENEDIA
MINE
CAS:25646-71-3
RTECS #:PB0431000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIETHYLHYDROXYLAMINE
CAS:3710-84-7
RTECS #:NC3500000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): NOT GIVEN
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. EYE CONTACT MAY CAUSE TRANSIENT
IRRITATION. SKIN CONTACT MAY CAUSE ALLERGIC SKIN REACTION. EXPECTED
TO BE A LOW INGESTION HAZARD. MAY C AUSE IRRITATION OF THE
GASTROINTESTINALTRACT.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION, SKIN IRRITATION, GI TRACT
IRRITATION, ALLERGIC SKIN REACTION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMEEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER IF ALLOWABLE WITH LARGE AMOUNTS
OF WATER. OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT
MATERIAL, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN
SURFACE TO REMOVE RESIDUA L CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION. WASH
THOROUGHLY AFTER HANDLING. KEEP FROM CONTACT WITH OXIDIZING
MATERIALS. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:KEEP AWAY FROM INCOMPATIBLE MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
================= Stability and Reactivity Data =================
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. MAY REQUIRE NEUTRALIZATION IF PH
< 2.0 OR PH > 12.5. DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE ANDLOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TURBO-WASH SOFT SUDS
CAGE:EO400
CAGE:70842
CAGE:050Q3
CAGE:EO400
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT GIVEN FOR PRODUCT AS A WHOLE
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT CAUSES MODERATE EYE
IRRITATION. SKIN CONTACT CAUSES SLIGHT IRRITATION. CHRONIC EXPOSURE
CAUSES DRYNESS, REDDENING OF SKIN.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION, SKIN IRRITATION, SKIN
DRYNESS/REDNESS.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYES AND SKIN: REMOVE CONTAMINATED CLOTHING. FLUSH EXPOSED
AREAS WITH WATER. INGESTION: INDUCE VOMITING. SEEK MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:NONFLAMMABLE. USE EXTINGUISHING MEDIA SUITABLE FOR
SURROUNDING FIRE.
Fire Fighting Procedures:NONFLAMMABLE. USE STANDARD FIREFIGHTING
PROCEDURES FOR SURROUNDING MATERIALS IN THE FIRE.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH AREA WITH WATER INTO SEWER. CAUTION:
FLOORS MAY BE EXTREMELY SLIPPERY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT OR OPEN FLAMES.
STORE IN A COOL DRY PLACE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL CONDITIONS
Ventilation:NONE REQUIRED UNDER NORMAL CONDITIONS
Other Protective Equipment:AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:210F,99C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:> 1
Spec Gravity:1.15
Evaporation Rate & Reference:1.0 (BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:THICK PASTE-LIKE LIQUID, VERY SLIGHT PLEASANT
SMELLING ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDEARL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:GASKET
Preparer's Name:HMIS TECHNICIAN
CAGE:JO760
CAGE:2T830
CAGE:51226
CAGE:98247
CAGE:00198
CAGE:JO760
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:SYNTHETIC RUBBER
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE:MINOR EYS/SKIN IRRITATION.
INGESTION- IRRITATION OF GI TRACT. INHALATION-IRRITATION OF
RESPIRATORY TRACT. CHRONIC: ASBESTOSIS, LUNG CANCER, &
MESOTHELIOMA, ALL OF WHICH ARE DISABLING AND FATAL D ISEASES OF THE
LUNG. INHALATION AND INGESTION OF ASBESTOS FIBERS MAY CAUSE CANCER
OF THE BOWEL.
Explanation of Carcinogenicity:ASBESTOS IS A KNOWN HUMAN CARCINOGEN.
Effects of Overexposure:INHALATION: FATIGUE AND SHORTNESS OF BREATH
THAT GETS WORSE WITH TIME AND EVENTUALLY BECOMES DISABLING. EYES:
IRRITATION. SKIN: IRRITATION. INGESTION: MILD STOMACH DISTRESS.
DIARRHEA, VOMITING, AND NA USEA.
Medical Cond Aggravated by Exposure:ASTHMA, EMPHYSEMA, AND TUBERCULOSIS
ARE ALL GENERALLY AGGRAVATED BY EXPOSURE TO ASBESTOS FIBERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SEE DOCTOR. EYES: RINSE
THOROUGHLY WITH WATER FOR 15 MINUTES. SEE DOCTOR. SKIN: WASH
THOROUGHLY WITH SOAP AND WATER. IF IRRITATION PERSISTS, SEE DOCTOR.
INGESTION: DIL UTE WITH WATER. DO NOT INDUCE VOMITING.SEE DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:NOT REQUIRED
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM THE MATERIAL WITH A HEPA FILTERED
VACUUM. THE EQUIPMENT SHALL BE USED & EMPTIED SO AS TO MINIMIZE THE
RE-ENTRY OF ASBESTOS INTO THE WORKPLACE. OTHERWISE, WET THE
MATERIAL WITH WATER & SURFACTAN T AND THEN SHOVEL OR MOP UP
CONTAMINATION.
======================Handling and Storage ======================
Handling and Storage Precautions:GASKET IS NONFRIABLE & WILL NOT SHED
FIBERS IN NORMAL USE AND STORAGE. USED GASKETS SHALL BE WETTED
BEFORE, DURING & AFTER DISASSEMBLY FROM AN ENGINE.
Other Precautions:IF IT IS NECESSARY TO CUT OR IMPACT THE GASKET WHILE
INSTALLING IT, WEAR A RESPIRATOR AND PROTECTIVE CLOTHING. USED
GASKETS SHALL BE IDENTIFIED AND DISPOSED OF IN ACCORDANCE WITH ALL
LOCAL, STATE AND FEDERAL REGULATIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED HEPA RESPIRATOR IF
REQUIRED. WEAR SELF-CONTAINED BREATHING APPARATUS IF REQUIRED FOR
HIGH LEVELS OF CONTAMINATES.
Ventilation:LOCAL EXHAUST SUFFICIENT TO ENTRAIN ALL PARTICULATE
EMISSIONS. HEPA FILTER REQUIRED. NO LEAKS ON PRESSURE SIDE OF FAN.
Other Protective Equipment:USE COVERALLS OR DISPOSABLE CLOTHING.
Work Hygienic Practices:WET WORK TO THE DEGREE POSSIBLE. WASH HANDS
AFTER HANDLING GASKET. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
MSDS GENERATED BY HMIS TECHNICIAN. MANUFACTURER IS UNKNOWN OR OUT OF
BUSINESS.
================== Physical/Chemical Properties ==================
HCC:T6
Solubility in Water:INSOLUBLE
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG MINERAL ACIDS, AND STRONG ALKALIS
Stability Condition to Avoid:ACCUMULATIONS OF DUST
Hazardous Decomposition Products:ASBESTOS DUST
==================== Disposal Considerations ====================
Waste Disposal Methods:WET THE MATERIAL WITH WATER AND SURFACTANT.
PLACE IN 6 MIL THICK POLYETHYLENE PLASTIC BAG. PLACE THESE BAGS
INTO ANOTHER POLY BAG OR A SAFE PLACE UNTIL IT CAN BE SHIPPED TO AN
APPROVED DISPOSAL SITE. IDENTIFY WITH ASBESTOS CANCER WARNING
LABEL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:284 PWC POLYURETHANE AEROSOL COLOR
CAGE:58977
CAGE:58977
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 34%
OSHA PEL:750 PPM
ACGIH TLV:750 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:BUTYL ACETATE (N-BUTYL ACETATE) *95-1*
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 5%
Other REC Limits:150 PPM
OSHA PEL:150 PPM
ACGIH TLV:150 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *95-1*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 13%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: <5%
Other REC Limits:525 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 15%
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: <5%
Other REC Limits:1000 PPM
OSHA PEL:800 PPM
ACGIH TLV:800 PPM
Ingred Name:BUTANE, N-BUTANE
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: 5%
Other REC Limits:800 PPM
OSHA PEL:600 PPM
ACGIH TLV:600 PPM
Ingred Name:VOLATILE ORGANIC CONTENT: 5.07 LBS/GAL
RTECS #:9999999VO
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 9750 MG/KG ACETONE
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: ANESTHETIC, RESPIRATORY
TRACT IRRITATION, NERVOUS SYSTEM DEPRESSION. EYES: IRRITATION.
SKIN: PRIMARY IRRITATION, DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, NAUSEA, DIZZINESS, HEADACHE,
UNCONSCIOSNESS, BURNING SENSATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. SKIN:
WASH AFFECTED AREA. EYES: FLUSH IMMEDIATELY W/WATER FOR 15 MINS.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-14.8F
Lower Limits:0.7
Upper Limits:12.8
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE, BUT WATER
SPRAY MAY BE USED TO COOL CONTAINERS EXPOSED TO HEAT/FIRE TO
PREVENT PRESSURE BUILD UP.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE DUE TO
BUILD UP OF PRESSURE FROM EXTREME HEAT/FIRE. AEROSOL SPRAY IS
EXTREMELY FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES. VENTILATE AREA & SOAK
UP W/INERT ABSORBENT USING NON-SPARKING TYPE TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE >120F, NEAR IGNITION
SOURCES.
Other Precautions:AVOID CONTACT W/EYES & SKIN, PROLONGED/REPEATED
CONTACT. DON'T BREATHE VAPORS, TAKE INTERNALLY. SMOKING SHOULD BE
STRICTLY PROHIBITED WHILE USING PRODUCT. DUST FROM SANDING DRY
PAINT FILMS SHOULD BE T REATED AS A NUISANCE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:OUTDOORS: APPROVED PARTICULATE FILTER TO REMOVE
ANY AIRBORNE OVERSPRAY. RESTRICTED AREAS W/POOR VENTILATION & CLOSE
TO TLV: WEAR A NIOSH APPROVED RESPIRATOR W/ORGANIC VAPOR CARTRIDGE.
Ventilation:ADEQUATE TO KEEP BELOW TLV.
Other Protective Equipment:EYE WASH FOUNTAIN, SAFETY SHOWER, IMPERVIOUS
APRON
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:-10F
Vapor Density:>1
Spec Gravity:0.7
Evaporation Rate & Reference:FASTER THAN N-BU AC
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OPAQUE LIQUID W/SOLVENT BASED ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPS, EXTREME HEAT, FIRE, SPARKS,
FLAME & OTHER IGNITION SOURCES.
Hazardous Decomposition Products:CO, CO2, HYDROGEN CHLORIDE, TRACES OF
PHOSGENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T INCINERATE CLOSED CONTAINERS. FLAMMABLE LIQUID
UN1950 CLASS 9.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:59D DULUX ALKYD ENAMEL
Preparer's Name:T R LOUER
CAGE:23027
CAGE:90227
CAGE:23027
============= Composition/Information on Ingredients =============
Ingred Name:P-TERY-BUTYLBENZOIC ACID, PENTAERYTHRITOL, PHTHALIC
ANHYDRIDE, SOYBEAN OIL POLYMER
CAS:68083-25-0
Ingred Name:LINSEED OIL, POLYMER WITH CONJUGATED SAFFLOWER OIL,
GLYCEROL, ISOPHTHALIC ACID, ALKYD RESIN C
CAS:68213-52-5
Ingred Name:SOYBEAN OIL, POLYMER W/GLYCEROL & PHTHALIC ANHYDRIDE
*96-3*
CAS:66070-61-9
Ingred Name:SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC, HIGH FLASH
AROMATIC NAPHTHA, C8&10 AROMATIC HYDROCARBON *96-3*
CAS:64742-95-6
RTECS #:WF3400000
Ingred Name:HEAVY AROMATIC SOLVENT NAPHTHA PETROLEUM *96-3*
CAS:64742-94-5
RTECS #:WF3100000
Ingred Name:MEDIUM ALIPHATIC NAPHTHA (AROMATIC 100), PARAFFIN-NAPTHANES
MINERAL SPIRITS * 96-3 *
CAS:64742-88-7
Other REC Limits:100 PPM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:C. I. PIGMENT BLUE 15, COPPER PHTHALOCYANINE BLUE
CAS:147-14-8
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM
Ingred Name:LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA, LACOLENE * 96-3 *
CAS:64742-89-8
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:VOLATILE ORGANIC CONTENT: 4.4 LBS/GAL
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE NOSE & THROAT
IRRITATION. EYES: MAY CAUSE IRRITATION/BURNING. SKIN: IRRITATION &
DERMATITIS. REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE
PERMANENT BRAIN & NERVOUS SYSTE M DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:GI DISTRESS, IRRITATION, EYE WATERING,
HEADACHES, NAUSEA, DIZZINESS, LOSS OF COORDINATION, BURNING,
DISCOMFORT.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: IMMEDIATELY FLUSH
W/PLENTY OF WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:<73F
Lower Limits:0.8
Upper Limits:11.5
Extinguishing Media:WATER SPRAY, FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT & SCBA. WATER
FROM FOG NOZZLES MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:WHEN HEATED > THE FLASH POINT, EMITS
FLAMMABLE VAPORS WHEN MIXED W/AIR, CAN BURN/BE EXPLOSIVE. FINE
MISTS/SPRAYS MAY BE FLAMMABLE AT TEMPS < THE FLASH POINT.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE SOURCES OF IGNITION.
PREVENT SKIN CONTACT & BREATHING OF VAPOR. WEAR A PROPERTY FITTED
VAPOR/PARTICULATE RESPIRATOR (NIOSH/MSHA TC-23C). CONFINE & REMOVE
W/INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS, FLAME.
CLOSE CONTAINER AFTER EACH USE. GROUND CONTAINERS WHEN POURING.
DON'T STORE >120F.
Other Precautions:OBSERVE LABEL PRECAUTIONS. DON'T SAND, FLAME CUT,
BRAZE/WELD DRY COATING W/O A NIOSH/MSHA APPROVED
RESPIRATOR/APPROPRIATE VENTILATION. DON'T PERMIT ANYONE W/O
PROTECTION IN THE PAINTING AREA. DON'T BR EATHE VAPORS/MISTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A PROPERLY FITTED VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA TC-23C DURING APPLICATION/IN
CONFINED SPACES, WEAR A POSITIVE PRESSURE, SUPPLIED AIR RESPIRATOR
TC-19C.
Ventilation:SUFFICIENT IN VOLUME & PATTERN TO KEEP CONTAMINANTS <
APPLICABLE OSHA LIMITS.
Other Protective Equipment:COVERALLS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE
EATING/SMOKING.
Supplemental Safety and Health
PERCENT VOLATILE BY VOLUME: 61.2-74.2.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:172-415F
Vapor Density:>1
Evaporation Rate & Reference:LESS THAN ETHER
Solubility in Water:MISCIBLE
Percent Volatiles by Volume:(SUPP)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORSEEABLE.
Stability Condition to Avoid:HEAT, SPARKS, FLAME, TEMPS >120F.
Hazardous Decomposition Products:CO, CO2, SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE/DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T ALLOW MATERIAL TO CONTAMINATE GROUND WATER
SYSTEMS. DON'T INCINERATE IN CLOSED CONTAINERS. FLAMMABLE LIQUID
UN1263.
| 1 | eyes_protection_mandatory |
=======================================================
NIIN: 00-935-6609
Product ID: SO SURE WHITE 17875 (144-170)
Cage: 0FTT5
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 0FTT5
=======================================================
Contractor Summary
=======================================================
Cage: 0FTT5
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: LACQUER
Specification Number: MIL-L-81352A
Unit of Issue: PT
UI Container Qty: 0
=======================================================
Ingredients
=======================================================
Cas: 108-88-3
RTECS #: XS5250000
% Wt: 6.85
Other REC Limits: NONE SPECIFIED
OSHA PEL: 200 PPM/150 STEL
ACGIH TLV: 50 PPM; 9293
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 67-64-1
RTECS #: AL3150000
% Wt: 35.62
Other REC Limits: NONE SPECIFIED
OSHA PEL: 1000PPM
ACGIH TLV: 750PPM/1000STEL;9293
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 74-98-6
RTECS #: TX2275000
% Wt: 18.72
Other REC Limits: NONE SPECIFIED
OSHA PEL: 1000 PPM
ACGIH TLV: 1000 PPM
------------------------------
Cas: 78-93-3
RTECS #: EL6475000
% Wt: 9.13
Other REC Limits: NONE SPECIFIED
OSHA PEL: 200 PPM
ACGIH TLV: 200 PPM
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 112-07-2
RTECS #: KJ8925000
% Wt: 2.28
Other REC Limits: NONE SPECIFIED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Cas: 71-36-3
RTECS #: EO1400000
% Wt: 2.28
Other REC Limits: NONE SPECIFIED
OSHA PEL: 100 PPM
ACGIH TLV: S, C 50 PPM; 9293
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 85-68-7
RTECS #: TH9990000
% Wt: <2.28
Other REC Limits: NONE SPECIFIED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
EPA Rpt Qty: 100 LBS
DOT Rpt Qty: 100 LBS
------------------------------
Cas: 84540-57-8
% Wt: 6.85
Other REC Limits: NONE SPECIFIED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
RTECS #: 9999999VO
Other REC Limits: NONE SPECIFIED
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: CONCENTRATING/INHALING CONTENTS-HARMFUL/FATAL. REPORTS
ASSOCIATE REPEATED/PROLONGED OCCUPATIONAL OVEREXPOSURE W/PERMANENT
BRAIN/NERVOUS SYSTEM DAMAGE. CONFINED AREAS/HIGH CONCENTRATIONS ARE
ANESTHETIC . IRRITATION TO SKIN/RESPIRATORY TRACT.HARMFUL IF SWALLOWED.
SEVERE EYE IRRITATION.
Signs And Symptions Of Overexposure: IRRITATION TO EYES, THROAT, AND
RESPIRATORY TRACT. MAY CAUSE HEADACHES, NAUSEA, AND VOMITING. OVEREXPOSURE:
LIGHT HEADEDNESS, STAGGER, GIDDINESS, AND POSSIBLE NAUSEA.
Medical Cond Aggravated By Exposure: RESPIRATORY AILMENTS.
First Aid: SKIN/CLOTHES: WASH W/SOAP/WATER; WASH CLOTHES BEFORE REUSE. EYES:
FLUSH W/WATER 15 MINUTES/CONTACT PHYSICIAN/OPHTHALMOLOGIST IMMEDIATELY.
INGEST: DO NOT INDUCE VOMITING. GET IMMEDIATE MEDICAL AID. INH ALE: MOVE TO
FRESH AIR/ARTIFICIAL RESPIRATION IF NEEDED/MEDICAL AID. NEVER GIVE ANYTHING
BY MOUTH TO AN UNCONSCIOUS PERSON.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION AND VENTILATE AREA.
MOP SPILLS WITH INERT ABSORBENT. AVOID BREATHING VAPORS.
Waste Disposal Methods: IN ACCORDANCE W/APPLICABLE LOCAL, STATE AND FEDERAL
REGULATIONS. DO NOT PUNCTURE, INCINERATE, STORE ABOVE 120F. EXPOSURE TO HEAT
OR PROLONGED EXPOSURE TO SUN: CONTAINER MAY BURST. DISCARD EMPTY CAN IN
TRASH PICK-UP. DO NOT PUT IN HOME TRASH COMPACTOR
Handling And Storage Precautions: KEEP OUT OF REACH OF CHILDREN.
CAUTION-CONTENTS UNDER PRESSURE. DO NOT STORE ABOVE 120F. AVOID BREATHING
SPRAY, MIST OR VAPOR.
Other Precautions: AVOID CONTACT WITH EYES AND SKIN. USE WITH GOOD VENTILATION.
READ ENTIRE LABEL BEFORE USING. FOLLOW ALL DIRECTIONS. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING AND INHALING OR SWALLOWING MAY BE H ARMFUL OR
FATAL.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NR
Autoignition Temp Text: 874F
Lower Limits: 1.8
Upper Limits: 9.5
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, SAND, WATER SPRAY.
Fire Fighting Procedures: WATER INEFFECTIVE/USED TO COOL EXPOSED CONTAINERS.
WEAR SELF-CONTAINED BREATHING APPARATUS. USE SHIELDING TO PROTECT PERSONNEL
FROM BURST/RUPTURE/VENT CONTAINER
Unusual Fire/Explosion Hazard: DO NOT SPRAY NEAR OPEN FLAME. AT ELEVATED
TEMPERATURE (OVER 120F) CONTAINERS MAY VENT/RUPTURE/BURST. AEROSOL CONTAINER;
DO NOT EXPOSE TO TEMPERATURES ABOVE 120F
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE BELOW TLV. USE NIOSH/MSHA APPROVED MASK ABOVE TLV.
Ventilation: LOCAL EXHAUST: PREFERRED. MECHANACAL: ACCEPTABLE AT POINT OF MIST
OR SPRAY RELEASE.
Other Protective Equipment: IMPERVIOUS CLOTHES TO PROTECT SKIN. EYE WASH
STATION.
Work Hygienic Practices: USE GOOD PERSONAL HYGIENE. DO NOT EAT, DRINK OR SMOKE
WHILE USING PRODUCT.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: V3
Vapor Pres: 65 @ 68 F
Vapor Density: 1.522
Spec Gravity: 0.904 (WATER=1)
Solubility in Water: NO
Appearance and Odor: WHITE/PAINT
Percent Volatiles by Volume: 84%
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: EXTREME HEAT
Hazardous Decomposition Products: CARBON MONOXIDE, AND POSSIBLE HYDROGEN
CHLORIDE
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 93357
Product ID: SO SURE WHITE 17875 (144-170)
Review Date: 09/02/1992
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: PT
Container QTY: 0
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: DTJ
Symbols: D
DOT Proper Shipping Name: CONSUMER COMMODITY
Hazard Class: ORM-D
Label: NONE
Non Bulk Pack: 156,306
Bulk Pack: NONE
Max Qty Pass: 30KGGROSS
Max Qty Cargo: 30KGGROSS
Vessel Stow Req: A
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: AKH
IMO Proper Shipping Name: AEROSOLS/AEROSOL PRODUCT ?
IMDG Page Number: SEE 9022
UN Number: 1950
UN Hazard Class: 9?
IMO Packaging Group: -
Subsidiary Risk Label: -
EMS Number: 2-13
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ALS
IATA UN ID Num: 1950
IATA Proper Shipping Name: AEROSOLS, FLAMMABLE
IATA PSN Modifier: (EACH NOT EXCEEDING 1 L CAPACITY)
IATA UN Class: 2.1
IATA Label: FLAMMABLE GAS
Packing Note Passenger: 203
Max Quant Pass: 75KG
Max Quant Cargo: 150KG
Packaging Note Cargo: 203
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ALS
AFI Proper Shipping Name: AEROSOLS, NONFLAMMABLE, N.O.S.
AFI PSN Modifier: CONTAINING SUBSTANCES IN CLASS 8, PACKING GROUP I OR II
AFI Hazard Class: FORB
Back Pack Reference: FORBIDDEN
=======================================================
HAZCOM Label
=======================================================
Product ID: SO SURE WHITE 17875 (144-170)
Cage: 0FTT5
Company Name: LHB INDUSTRIES
Street: 8833 FLEISCHER PLACE
Zipcode: 63134
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: CONCENTRATING/INHALING CONTENTS-HARMFUL/FATAL. REPORTS
ASSOCIATE REPEATED/PROLONGED OCCUPATIONAL OVEREXPOSURE W/PERMANENT
BRAIN/NERVOUS SYSTEM DAMAGE. CONFINED AREAS/HIGH CONCENTRATIONS ARE
ANESTHETIC . IRRITATION TO SKIN/RESPIRATORY TRACT.HARMFUL IF SWALLOWED.
SEVERE EYE IRRITATION. IRRITATION TO EYES,
THROAT, AND RESPIRATORY TRACT. MAY CAUSE HEADACHES, NAUSEA, A ND VOMITING.
OVEREXPOSURE: LIGHT HEADEDNESS, STAGGER, GIDDINESS, AND POSSIBLE NAUSEA.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:7802 TAHOE BLUE, FAST DRY ACRYLIC ENAMEL 78
CAGE:MART2
CAGE:MART2
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:ING 10:CAUSE CNTNR TO BURST. DO NOT TAKE INTERNALLY. KEEP
OUT OF REACH OF CHILDREN. COATING MAY CONTAIN MATLS (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:CLASSIFIED AS NUISANCE PARTICULATES WHICH MAY BE
PRESENT @ HAZ LEVELS ONLY DURING SANDING/ABRADING DRIED FILM.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:MSHA APPRVD PARTICULATE RESP FOR PROT AGAINST
NON-VOLATILE MATLS.
RTECS #:9999999ZZ
Ingred Name:VENT:1910.94, 1910.107, 1910.108.
RTECS #:9999999ZZ
Ingred Name:SUP DATA:NOTE:TOLUENE, CAS#108-88-3 APPEARS ON THE NAVY
LISTING OF OCCUP REPRO HAZ. SEEK CONSULTATION FROM APPROP(ING 16
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
Ingred Name:ING 15:HLTH PROFESSIONALS CONCERN LATEST HAZ LIST INFO AND
SAFE HANDLING AND EXPOS RECOMMENDATIONS.
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
Ingred Name:ING 9:INCIN/EXPOSE TO TEMP >120F. HEAT FROM SUNLIGHT,
RADIATORS, STOVES, HOT WATER & OTHER HEAT SOURCES COULD (ING 11)
RTECS #:9999999ZZ
Ingred Name:PROPANE (PROPELLANT). VP:760
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 13%
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:PROPANE, 2-METHYL-; (2-METHYLPROPANE) (PROPELLANT)). VP:760
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 14%
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 14%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BENZENE, ETHYL-; (ETHYLBENZENE). VP:7.1
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 2%
OSHA PEL:100 PPM;125 PPM STEL
ACGIH TLV:100 PPM;125 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE. VP:5.9
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 19%
OSHA PEL:100 PPM;150 PPM STEL
ACGIH TLV:100 PPM;150 PPM ]TEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE. VP:180
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 18%
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPIONIC ACID, 3-ETHOXY-, ETHYL ESTER;
(ETHYL-3-ETHOXYPROPIONATE). VP:1.1
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: 2%
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 2%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:OTHER PREC:CONSULT NFPA CODE. USE APPRVD BONDING &
GROUNDING PROCS. CONTENTS UNDER PRESS. DO NOT PUNCTURE, (ING 10)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRIT OF EYES, SKIN & RESP SYS.
MAY CAUSE NERV SYS DEPRESS. EXTREME OVEREXP MAY RESULT IN UNCON &
POSS DEATH. HDCH, DIZZ, NAUS & LOSS OF COORDINATION ARE INDICATIONS
OF EXCESS EXPOS TO VAPS/SPRA Y MISTS. REDNESS & ITCH/BURNING
SENSATION MAY INDICATE EYE/EXCESS SKIN EXPOS. CHRONIC:PRLNG OVEREXP
TO (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:SOLV INGS MAY CAUSE ADVERSE EFTS TO
LIVER, URINARY, BLOOD FORMING, CARDIO-VASCULAR & REPRO SYS. RATS
EXPOSED TO TITANIUM DIOXIDE DUST @ 250 MG/M3 DEVEL LUNG CANCER,
HOWEVER, SUCH EXPOS LEVELSARE NOT ATTAINABLE IN WORKPLACE.
REPORTS HAVE ASSOC RPTD & PRLNG OVEREXP TO SOLV W/PERM BRAIN & NERV
SYS DMG. (SUPDAT)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM &
QUIET. SKIN:WASH AFFECTED AREA THORO W/SOAP & WATER. REMOVE CONTAM
CLTHG & LAUNDER BEFORE RE-USE. EYES:FLUSH W/LG AMTS OF WATER FOR AT
LEAST 15 MINUTES. GET MD. INGEST:NEVER GIVE ANYTHING BY MOUTH TO
UNCON PERSON. DO NOT INDUCE VOMIT. GIVE SEVERAL GLASSES OF WATER.
SEE MD.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:<0F,<-18C
Lower Limits:0.7%
Upper Limits:6%
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. H*2O SPRAY MAY BE INEFT. IF H*2O IS USED, FOG NOZZ ARE PREF. H*2O
MAY BE USED TO COOL CLSD CNTNRS (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPKS & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. APPLICATN TO HOT SURFS(SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE &
REMOVE W/INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE ONLY W/ADEQ VENT. AVOID BRTHG VAP
& SPRAY MIST. AVOID CONT W/SKIN & EYES. CONTENTS ARE EXTREMELY
FLAMM. KEEP AWAY FROM HEAT, SPKS & OPEN FLAME.
Other Precautions:VAPS WILL ACCUM READILY & MAY IGNITE EXPLOSIVELY.
DURING USE & UNTIL ALL VAPS ARE GONE:KEEP AREA VENTED; DO NOT
SMOKE; EXTING ALL FLAMES, PILOT LIGHTS & HEATERS; TURN OFF STOVES,
ELEC TOOLS & APPLIANC ES & ANY OTHER SOURCES OF IGNIT. (ING 9)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIMS BY VENT, WEAR PROPERLY FITTED NIOSH/MSHA APPRVD ORG
VAP/PARTICULATE RESP FOR PROT AGAINST INGS. WHEN SANDING,
WIREBRUSHING, ABRADING, BURNING/W ELDING DRIED FILM, WEAR NIOSH/
(ING 13)
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPT IF EXPOS TO MATLS IS
MAINTAINED BELOW APPLIC EXPOS LIMS. REFER TO OSHA STDS (ING 14)
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC:TO PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN
EXPOSED TO EXTREME HEAT. EXPLO HAZ:REQS SPECIAL PRECS. DURING EMER
CNDTNS OVEREXP TO DECOMP PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT B
E IMMED APPARENT. GET MD. EFTS OF OVEREXP:INTENT MISUSE BY DELIB
CONC & INHAL CONTENTS CAN BE HARMFUL/FATAL.(ING 15)
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:<0F,<-18C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:>75
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE:CO*2, CO, OXIDES OF METAL
INGREDIENTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM PROD MAY BE HAZ AS DEFINED UNDER RCRA
40 CFR 261. WASTE MUST BE TESTED FOR IGNITABILITY TO DETERMINE
APPLIC EPA HAZ WASTE NUMBERS. DO NOT INCIN. DEPRESSURIZE CNTNR.
DISP OF I/A/W FEDERAL, S TATE & LOCAL REGULATIONS REGARDING
POLLUTION.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:K-184
CAGE:2Y081
CAGE:2Y081
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2-AMINO-; (ETHANOLAMINE)
CAS:141-43-5
RTECS #:KJ5775000
OSHA PEL:3 PPM
ACGIH TLV:3 PPM;6 STEL
Ingred Name:BORATE COMPOUND; (BORATES)
OSHA PEL:N/K
ACGIH TLV:1 MG/M3 (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT W/SKIN OR EYES MAY CAUSE
IRRITATION. INGESTION MAY INJURE MOUTH & GASTROINTESTINAL TRACT.
INHALATION OF AIRBORNE MISTS WILL IRRITATE RESPIRATORY SYSTEM.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:SENSITIVE SKIN.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . EYES:WASH FROM EYES W/WATER FOR AT LEAST 15 MINUTES & SEE
MD IF IRRITATION PERSISTS. SKIN:WASH FROM SKIN W/WATER. INGEST:GIVE
LARGE QUANTITIES OF WATER & GET MEDICALATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER FOG, FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB ON SOLID ABSORBANT. WASH DOWN W/WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT MODERATE TEMPERATURES. KEEP
CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. RETURN EMPTY DRUMS TO
A LICENSED RECONDITIONING SERVICE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR PRODUCT
MISTS.
Ventilation:LOCAL EXHAUST &/OR MECHANICAL (GENERAL) VENTILATION
RECOMMENDED.
Other Protective Equipment:EMERG EYE WASH & DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:17.5
Spec Gravity:1.04 (H*2O=1)
Solubility in Water:COMPLETE
Appearance and Odor:YELLOW LIQUID; MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W ALL LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TIONA RCL-2
Preparer's Name:J.H. BLACKER
CAGE:46343
CAGE:46343
============= Composition/Information on Ingredients =============
Ingred Name:RUTILE; (TITANIUM DIOXIDE) (LIMITS GIVEN AS TITANIUM OXIDE)
CAS:1317-80-2
RTECS #:VM2940000
Fraction by Wt: 80-97%
Other REC Limits:15 MG/M3 (MFR)
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:SILICA GEL; (AMORPHOUS SILICA)
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 10% MAX
Other REC Limits:20 MPPCF (MFR)
OSHA PEL:6 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:ALUMINUM OXIDE (2:3); (AS AL*2O*3)(EPA LISTS ONLY FIBROUS
FORMS) (SARA III)
CAS:1344-28-1
RTECS #:BD1200000
Fraction by Wt: 6% MAX
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT):>9000 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:INERT NUISANCE DUST. TEMPORARY
DRYING EFFECT OR IRRITATION OF MUCOUS MEMBRANES MAY RESULT FROM
EXCESSIVE EXPOSURE. SKIN:NON-CORROSIVE, NON-IRRITATING,
NON-SENSITIZING, MAY HAVE A DRYING EFFECT O N SKIN. EYE:INERT
FOREIGN BODY HAZARD ONLY. INGEST:HARMLESS, PHYSIOLOGICALLY INERT.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.
SKIN:WASH WITH WATER AND MILD SOAP. INHAL:REMOVE TO FRESH AIR.
INGEST:NO TREATMENT REQUIRED. MATERIAL IS COMPLETELY ELIMINATED
THROUGH GI TRACT IN ABOUT 24 HOURS.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:NO FIRE HAZARD. MEDIA SUITABLE FOR SURROUNDING FIRE
.
Fire Fighting Procedures:NONE REQUIRED. USE NIOSH/MSHA APPROVED SCBA
AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:USE ANY FEASIBLE MECHANICAL MEANS - BROOM,
BRUSH, SCOOP, VACUUM OR WET ABSOSRBENT MATERIAL, BUT AVOID DUSTING
DURING CLEAN UP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED DUST RESPIRATOR IF TLV
IS OR MAY BE EXCEEDED.
Ventilation:LOCAL EXHAUST, IF REQUIRED TO MAINTAIN AIRBORNE
CONCENTRATIONS BELOW TLV.
Other Protective Equipment:NONE
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PH:(10% SLURRY) PH OF WATER SUSPENSION 5.5- 8.5.
================== Physical/Chemical Properties ==================
HCC:V7
Melt/Freeze Pt:M.P/F.P Text:3326F,1830C
Spec Gravity:3.7-4.2(H2O=1)
pH:SUPDAT
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE, TASTELESS, ODORLESS POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISP MUST BE I/A/W LOC, STATE & FED REGS . THIS
PROD WHEN SPILLED CAN BE DISP OF INTO SANITARY LANDFILL/INDUSTRIAL
WASTE DISP LANDFILL. PLEASE REVIEW APPROP STATE INDUSTRIAL WASTE
DISP REGS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS & NATURAL/SYNTHETIC RUBBER & STEEL COMPOSITION
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ETHYL ALCOHOL, DENATURED (A407) A407 20 010
Resp. Party Other MSDS Num.:08701
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ALCOHOL; LC50 (INHAL, MOUSE): 39 GM/M3/4H; LC50
(INHAL, RAT): 20000 PPM/10H; LD50 (ORAL, MOUSE): 3450 MG/KG; LD50
(ORAL, RABBIT): 6300 MG/KG; LD50 (ORAL, RAT): 7060 MG/KG
CAS:64-17-5
RTECS #:KQ6300000
Minumum % Wt:85.4
Maxumum % Wt:92.
Other REC Limits:N/K
OSHA PEL:1900 MG/M3;1000 PPM
OSHA STEL:N/K
ACGIH TLV:1880 MG/M3;1000 PPM
ACGIH STEL:N/K
Ingred Name:METHYL ALCOHOL; LC50 (INHAL, RAT): 64000 PPM/4H; LD50
(ORAL, MOUSE): 7300 MG/KG; LD50 (ORAL, RABBIT): 14200 MG/KG; LD50
(ORAL, RAT): 5628 MG/KG; LD50 (SKIN, RABBIT): 15800 MG/KG
CAS:67-56-1
RTECS #:PC1400000
= Wt:3.6
Other REC Limits:N/K
OSHA PEL:260 MG/M3;200 PPM
OSHA STEL:N/K
ACGIH TLV:262 MG/M3;200 PPM
ACGIH STEL:328 MG/M3;250 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPYL ALCOHOL; LD50 (ORAL, MOUSE): 3600 MG/KG; LD50
(ORAL, RABBIT): 6410 MG/KG; LD50 (ORAL, RAT): 5045 MG/KG; LD50
(SKIN, RABBIT): 12800 MG/KG
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 25% PPM
Other REC Limits:N/K
OSHA PEL:980 MG/M3;400 PPM
OSHA STEL:N/K
ACGIH TLV:983 MG/M3;400 PPM
ACGIH STEL:1230 MG/M3;500 PPM
Ingred Name:ACETONE; LC50 (INHAL, RAT): 50100 MG/M3/H8; LD50 (ORAL,
MOUSE): 3 GM/KG; LD50 (ORAL, RABBIT): 5340 MG/KG; LD50 (ORAL, RAT):
5800 MG/KG; LD50 (SKIN, RABBIT): 20 GM/KG
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 2% PPM
Other REC Limits:N/K
OSHA PEL:2400 MG/M3;1000 PPM
OSHA STEL:N/K
ACGIH TLV:1780 MG/M3;750 PPM
ACGIH STEL:2380 MG/M3;1000 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:BENZENE; LC50 (INHAL, MOUSE): 9980 PPM; LC50 (INHAL, RAT):
10000 PPM/7H; LD50 (ORAL, MOUSE): 4700 MG/KG; LD50 (ORAL, RAT): 930
MG/KG; LD50 (SKIN, RABBIT): >9400 MG/KG
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: TRACE
Other REC Limits:N/K
OSHA PEL:10 PPM
OSHA STEL:N/K
ACGIH TLV:32 MG/M3;10 PPM
ACGIH STEL:N/K
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:ACETALDEHYDE; LC50 (INHAL, RAT): 24 GM/M3/4H; LD50 (ORAL,
RAT): 661 MG/KG; LD50 (SKIN, RABBIT): 3540 MG/KG
CAS:75-07-0
RTECS #:AB1925000
Fraction by Wt: 10% PPM
Other REC Limits:N/K
OSHA PEL:360 MG/M3;200 PPM
OSHA STEL:N/K
ACGIH TLV:25 PPM
ACGIH STEL:C45 MG/M3;C25 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL ISOBUTYL KETONE; LC50 (INHAL, MOUSE): 23300 MG/M3;
LD50 (ORAL, MOUSE): 2671 MG/KG; LD50 (ORAL RAT): 2080 MG/KG; LD50
(SKIN, RABBIT): >20 GM/KG
CAS:108-10-1
RTECS #:SA9275000
= Wt:1.9
Other REC Limits:N/K
OSHA PEL:410 MG/M3;100 PPM
OSHA STEL:N/K
ACGIH TLV:205 MG/M3;50 PPM
ACGIH STEL:307 MG/M3;75 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TOLUENE; LC50 (INHAL, MOUSE): 400 PPM/24H; LC50 (INHAL,
RAT): 49 GM/M3/4H; LD50 (ORAL, RAT): 636 MG/KG; LD50 (SKIN,
RABBIT): 12124 MG/KG
CAS:108-88-3
RTECS #:XS5250000
= Wt:.8
Other REC Limits:N/K
OSHA PEL:see Table Z-2
OSHA STEL:N/K
ACGIH TLV:188 MG/M3;50 PPM
ACGIH STEL:N/K
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL ACETATE; LC50(INHAL, MOUSE): 45 GM/M3/2H; LC50(INHAL,
RAT): 200 GM/M3; LD50(ORAL, MOUSE): 4100 MG/KG; LD50(ORAL, RABBIT):
4935 MG/KG; LD50(ORAL, RAT): 5620 MG/KG; LD50(SKIN, RABBIT): >20
GM/KG
CAS:141-78-6
RTECS #:AH5425000
= Wt:1.3
Other REC Limits:N/K
OSHA PEL:1400 MG/M3;400 PPM
OSHA STEL:N/K
ACGIH TLV:1440 MG/M3;400 PPM
ACGIH STEL:N/K
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WATER; LD50 (ORAL, RAT): >90 ML/KG
CAS:7732-18-5
RTECS #:ZC0110000
= Wt:5.
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:LIGHT ALIPHATIC SOLVENT NAPHTHA (PETROLEUM); (SOLVENT
NAPHTHA (PETROLEUM), LIGHT ALIPHATIC)
CAS:64742-89-8
> Wt:.72
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: PRDCES IRRIT, CHARACTERIZED BY
BURNING SENSATION, REDNESS, TEARING, INFLAMM, & POSS CORNEAL
INJURY. MAY CAUSE PAINFUL SENSIT TO LIGHT. VAPS MAY CAUSE IRRIT.
SKIN: MAY CAUSE IRRIT. PRLNG &/OR RPT D CONT MAY CAUSE DEFAT &
DERM. MAY BE ABSORBED THRU SKIN. INGEST: MAY BE FATAL/CAUSE
BLINDNESS IF SWALLOWED. MAY CAUSE SYSTEMIC TOXICITY W/ACIDOSIS. MAY
CAUSE LIVER & KIDNEY DMG. MAY CAUSE CNS DEPRESS , CHARACTERIZED BY
EXCITEMENT, FOLLOWED BY HDCH, DIZZ, DROW, & NAUS. ADVANCED STAGES
MAY CAUSE COLLAPSE, UNCON, COMA & POSS DEATH DUE TO RESP FAILURE.
INHAL: INHAL OF HIGH CONCS MAY CAUSE CNS EFTS CHA RACTERIZED BY
HDCH, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:ISOPROPYL ALCOHOL: IARC: GROUP 3 CARCIN.
BENZENE: ACGIH: A1-CONFIRMED HUMAN CARCIN; CALIFORNIA:
CARCIN-INITIAL DATE 2/27/87; NIOSH: OCCUP CARCIN; NTP: KNOWN
CARCIN; OSHA: SELECT CARCIN; IARC: GRP 1 CA RCIN. ACETALDEHYDE:
ACGIH: A3-ANIMAL CARCIN; CALIFORNIA: CARCIN-INITIAL DATE 4/1/88;
NIOSH: OCCUP CARCIN; NTP: SUSPECT CARCIN; OSHA: POSS SELECT (SUP
DAT)
Effects of Overexposure:HLTH HAZ: DIZZ, UNCON & COMA. MAY CAUSE RESP
TRACT IRRIT. MAY CAUSE EFTS SIMILAR TO THOSE DESCRIBED FOR INGEST.
MAY CAUSE DROW, UNCON, & CNS DEPRESS. CHRONIC: CHRONIC INHAL &
INGEST MAY CAUSE EFTS SIM ILAR TO THOSE OF ACUTE INHAL & INGEST.
PRLNG/RPTD SKIN CONT MAY CAUSE DEFAT & DERM. PRLNG/RPTD EXPOS MAY
CAUSE ADVERSE REPRO EFTS. MAY CAUSE FETAL EFTS. TOLUENE & BENZENE
APPEAR ON THE NAVY OCCUP CHEM REPRO HAZ LIST. SEEK CONSULTATION
FROM APPROP HLTH PROFESSIONALS CONCERNING LATEST HAZ LIST INFO &
SAFE HNDLG & EXPOS INFO .
======================= First Aid Measures =======================
First Aid:EYES: IMMED FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINUTES,
OCCASIONALLY LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. SKIN:
GET MED AID. IMMED FLUSH SKIN W/PLENTY OF SOAP & WATER FOR AT LEAST
15 MI NUTES WHILE REMOVING CONTAMINATED CLOTHING & SHOES. INGEST:
IF CONSCIOUS & ALERT, GIVE 2-4 CUPFULS OF MILK/WATER. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. GET MED AID. INDUCE
VOMITING BY GIVING 1 TEASPOON OF SYRUP OF IPECAC. INHAL: GET MED
AID IMMED. REMOVE FROM EXPOS TO FRESH AIR IMMED. IF NOT BREATHING,
GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, GIVE
OXYGEN. NOTES TO M D: TREAT SYMPTOMATICALLY & SUPPORTIVELY.
===================== Fire Fighting Measures =====================
Flash Point:=13.9C, 57.F
Autoignition Temp:=362.8C, 685.F
Lower Limits:3.3% (ING 1)
Upper Limits:19% (ING 1)
Extinguishing Media:USE WATER SPRAY, DRY CHEMICAL, CHEMICAL FOAM OR
ALCOHOL-RESISTANT FOAM. FOR LARGE FIRES, USE DRY CHEMICAL, CARBON
DIOXIDE, ALCOHOL-RESISTANT FOAM, OR WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO COOL FIRE-EXPOSED CONTAINERS. WATER
MAY BE INEFFECTIVE. DO NOT USE STRAIGHT STREAMS OF WATER. COOL
CONTAINERS WITH FLO ODING QUANTITIES OF WATER UNTIL WELL AFTER FIRE
IS OUT.
Unusual Fire/Explosion Hazard:VAPORS MAY FORM EXPLOSIVE MIXTURE WITH
AIR. VAPORS CAN TRAVEL TO A SOURCE OF IGNITION & FLASH BACK.
CONTAINERS MAY EXPLODE IN THE HEAT OF A FIRE. FLAMMABLE LIQUID. MAY
FORM EXPLOSIVE PEROXIDES. VAPORS MAY BE HEAVIER THAN AIR. THEY CAN
SPREAD ALONG GROUND & COLLECT IN LOW OR CONFINED AREAS. NFPA
RATING: NOT PUBLISHED.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTIVE EQUIPMENT AS
INDICATED IN CONTROL MEASURES SECTION. ABSORB SPILL WITH INERT
MATERIAL (E.G., DRY SAND OR EARTH), THEN PLACE INTO A CHEMICAL
WASTE CONTAINER. REMOVE ALL SO URCES OF IGNITION. A VAPOR
SUPPRESSING FOAM MAY BE USED TO REDUCE VAPORS.
======================Handling and Storage ======================
Handling and Storage Precautions:USE W/ADEQ VENT. GROUND & BOND
CONTAINERS WHEN TRANSFERRING MATL. AVOID CONT W/EYES, SKIN, &
CLOTHING. EMPTY CONTAINERS RETAIN PROD RESIDUE (LIQUID &/OR VAPOR),
& CAN BE DANGEROUS. KEEP CONTAINER TIGH TLY CLOSED. AVOID CONT
W/SKIN, EYES & CLOTHING. AVOID INGEST & INHAL.
Other Precautions:DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL,
GRIND/EXPOSE EMPTY CONTRS TO HEAT, SPKS/OPEN FLAMES. KEEP AWAY FROM
HEAT, SPKS, & FLAME. KEEP AWAY FROM SOURCES OF IGNIT. STORE IN
TIGHTLY CLSD CONT RS. STORE IN COOL, DRY, WELL-VENTILATED AREA AWAY
FROM INCOMPATIBLE SUBSTANCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
29 CFR 1910.134 OR EUROPEAN STANDARD EN 149. ALWAYS USE A NIOSH OR
EUROPEAN STANDARD EN 149 APPROVED RESPIRATOR WHEN NECESSARY.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
AIRBORNE CONCENTRATIONS BELOW THE PERMISSIBLE EXPOSURE LIMITS.
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT
SKIN EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
CARCIN: CARCIN; IARC: GRP 2B CARCIN. TOLUENE: IARC: GRP 3 CARCIN. WASTE
DISP METH: CAS# 67-64-1: WASTE # U002 (IGNIT WASTE). CAS# 71-43-2:
WASTE # U019 (IGNIT WASTE; TOX WASTE). CAS# 75-07-0: WASTE. C AS#
67-56-1, 67-64-1 & 71-43-2 ARE BANNED FROM LAND DISP ACCORDING TO
RCRA. CAS# 75-07-0 IS BANNED.
================== Physical/Chemical Properties ==================
Boiling Pt:=78.5C, 173.3F
Melt/Freeze Pt:=-90.C, -130.F
Vapor Pres:25 MM HG
Vapor Density:1.6(ING 1)
Spec Gravity:0.7905
Viscosity:NOT AVAILABLE
Evaporation Rate & Reference:2.0
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID WITH AROMATIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ISOPROPANOL IS SUSCEPTIBLE TO AUTOXIDATION & THEREFORE SHOULD BE
CLASSIFIED AS PEROXIDIZABLE, ACIDS (MINERAL, NON-OXIDIZING, E.G.
HYDROCHLORIC, HYDROFLUORIC, MURIATIC, PHOSPHORIC, NITRIC & SULFURIC
ACIDS), ACIDS (ORG, E.G.
Stability Condition to Avoid:THIS MATERIAL MAY BE SENSITIVE TO PEROXIDE
FORMATION, INCOMPATIBLE MATERIALS, IGNITION SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
=================== Toxicological Information===================
Toxicological Information:REPRO EFTS: PRENATAL EXPOS TO ETHANOL IS
ASSOC W/DISTINCT PATTERN OF CONGENITAL MALFORMATIONS THAT HAVE BEEN
COLLECTIVELY TERMED FETAL ALCOHOL SYNDROME. AMONG CHARACTS OF THIS
SYNDROME ARE INTRAUTERIN E & POSTNATAL GROWTH DEFICIENCY, A
DISTINCTIVE PATTERN OF PHYSICAL MALFORMATION, &
BEHAVIORAL/COGNITIVE IMPAIRMENT SUCH AS FINE MOTOR DYSFUNCTION &
MENTAL RETARDATION. NOT ALL AFFECTED CHILDREN HAVE A LL OF FEATURES
OF SYNDROME. THIS SYNDROME HAS BEEN ASSOC W/ALCOHOLIC WOMEN WHO
DRANK HEAVILY & CHRONICALLY DURING PREGNANCY.
EPIDEMIOLOGY/TERATOGENICITY/NEUROTOX/MUTAGENICITY/OTHER STUDIES: NO
DATA AV AIL. CONT NEHC FOR MORE INFO .
===================== Ecological Information =====================
Ecological:ECOTOXICITY: 250 PPM/6HR/GOLDFISH/LETHAL/FRESH WATER.
ENVIRON FATE: ETHANOL: IN WATER, WILL VOLATILIZE & PROBABLY
DEGRADE. PHYSICAL/CHEM: NOT AVAIL. OTHER: NOT EXPECTED TO
BIOCONCENTRATE IN FISH. OTHE R INFO: (E.G. ALUMINUM CARBIDE,
CHLOROSILANE, HYDROGEN PHOSPHIDE, LITHIUM HYDRIDE), WATER REACTIVE
SUBSTANCES (E.G. ACETIC ANHYDRIDE, ALKYL ALUMINUM CHLORIDE, CALCIUM
CARBIDE, ETHYL DICHLOROSILANE).
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT W/FED, STATE,
& LOC REGS. RCRA D-SERIES MAX CONC OF CONTAMINANTS: CAS# 71-43-2:
WASTE # D018; REG LEVEL=0.5 MG/L. RCRA D-SERIES CHRONIC TOX
REFERENCE LEVELS: CAS# 71- 43-2: CHRONIC TOX REFERENCE LEVEL=0.005
MG/L. RCRA F/P-SERIES: NONE LISTED. RCRA U-SERIES: CAS# 67-5 6-1:
WASTE # U154 (IGNIT WASTE). (SUP DAT)
=================== MSDS Transport Information ===================
Transport Information:US DOT: SHIPPING NAME: ETHANOL SOLNS; HAZ CLASS:
3; UN #: UN1170; PACKING GRP: II. IMO/IATA/RID/ADR: NO INFO AVAIL.
FED REGS: CLEAN WATER ACT: CAS# 71-43-2/75-07-0/108-88-3: LISTED AS
HAZ SUBSTANCES U NDER CWA; CAS# 71-43-2/108-88-3: LISTED AS
PRIORITY POLLUTANT UNDER CWA; CAS# 71-43-2/108-88-3: LISTED AS TOX
POLLUTANTS UNDER CWA. OSHA: CAS# 75-07-0 CONSIDERED HIGHLY HAZ BY
OSHA. EUROPEAN LABELING I/A/W EC DIRECTIVES: HAZ SYMBOLS: F; RISK
PHRASES: R 11 HIGHLY FLAM; SFTY PHRASES: S 16 KEEP AWAY FROM
SOURCES OF IGNIT-NO SMKNG; S 2 KEEP OUT OF REACH OF CHILDREN; S 7
KEEP CONTR TIGHTLY CLSD. CONT N EHC FOR MORE INFO .
===================== Regulatory Information =====================
SARA Title III Information:SECTION 302(FINAL RQ):CAS#
67-56-1/67-64-1/108-10-1/141-78-6:5000LBS(2270KG);CAS#
71-43-2:10LBS(4.54KG), RECEIVES ADJUSTABLE R; CAS#
75-07-0/108-88-3:1000LBS(454KG). NONE OF CHEMS HAVE TPQ (SECTION 30
2). SARA CODES:CAS# 64-17-5/67-63-0/71-43-2:ACUTE, CHRONIC, FLAM;
CAS# 67-56-1/108-88-3:ACUTE, FLAM; CAS# 67-64-1:ACUTE, CHRONIC,
FLAM, SUDDEN RELEASE OF PRESS; CAS# 75-07-0/108-10-1:ACUTE,
CHRONIC, F LAM. REACTIVE; CAS# 141-78-6:FLAM. SECTION 313:CAS#
67-56-1/67-63-0/75-07-0/108-10-1:SUBJECT TO REPORTING REQS OF
SECTION 313 OF SARA TITLE III & 40 CFR PART 373. CAS#
67-63-0/108-10-1:CONCS TOO LOW T O BE REPORTABLE UNDER SECTION 313.
Federal Regulatory Information:ALL INGS ARE LISTED ON TSCA INVENTORY.
HLTH & SFTY REPORTING LIST: CAS# 67-63-0: EFFECTIVE DEC 15, 1986,
SUNSET DEC 15, 1996; CAS# 108-10-1/108-88-3: EFFECTIVE OCTOBER 4,
1982, SUNSET OCTOBER 4, 1992. CHEM TEST RULES: CAS# 67-63-0:
TESTING REQUIRED BY MFRS, IMPORTERS, PROCESSOR. SECTION 12B: CAS#
67-63-0/67-64-1/108-10-1/141-78-6: EXPORT NOTIFICATION
REQUIRED-SECTION 4. TSCA SIGNIFICANT NEW USE RU LE : NONE OF CHEMS
HAVE SNUR UNDER TSCA. CLEAN AIR ACT: CAS#
67-56-1/71-43-2/75-07-0/108-10-1/108-88 -3: LISTED AS HAZ AIR
POLLUTANTS (HAP). MATL DOES NOT CONTAIN ANY CLASS 1 OR 2 OZONE
DEPLETORS. (TRANSPORT INFO)
State Regulatory Information:ETHYL ALCOHOL, METHYL ALCOHOL, ISOPROPYL
ALCOHOL, ACETONE, BENZENE, ACETALDEHYDE, METHYL ISOBUTYL KETONE,
TOLUENE & ETHYL ACETATE CAN BE FOUND ON THE FOLLOWING STATE
RIGHT-TO-KNOW LISTS: CA, NJ, FL, P A, MN, MA. WATER & SOLV NAPHTHA
(PETRO) LIGHT ALIPHATIC ARE NOT PRESENT ON STATE LISTS FROM CA, PA,
MN, MA, FL/NJ. WARNING: BENZENE IS KNOWN TO STATE OF CA TO CAUSE
CANCER, BIRTH DEFECTS/OTHER REPRO H ARM; ACETALDEHYDE IS KNOWN TO
STATE OF CA TO CAUSE CANCER; ETHYL ALCOHOL IS KNOWN TO STATE OF CA
TOCAUSE BIRTH DEFECTS/OTHER REPRO HARM. CA NO SIGNIFICANT RISK
LEVEL: CAS# 71-43-2=7 UG/DAY; CAS# 75-07-0: INHAL=90 UG/DAY.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:GSA
CAGE:53798
CAGE:53798
============= Composition/Information on Ingredients =============
Ingred Name:METHYLENE CHLORIDE(SARA III)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: <60%
Other REC Limits:N/K
OSHA PEL:500 PPM/C,1000; Z2
ACGIH TLV:50 PPM, A2; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:HARMFUL OR FATAL IF SWALLOWED.CAN
CAUSE LIVER DISEASE.
Explanation of Carcinogenicity:DICHLOROMETHANE:INADEQ EVID FOR CARCIN
IN HUM,SUFF EVID IN ANIM (IARC 1987).ACGIH A2:SUSPECTED HUMAN
CARCIN (1989).
Effects of Overexposure:EYES/SKIN:DIRECT CONTACT MAY CAUSE
IRRITATION.INGESTION:HARMFUL OR FATAL IF SWALLOWED.INHALATION:VAPOR
HARMFUL.INHAL OF VAP MAY CAUSE
CONFUSION,LIGHTHEADEDNESS,NAUSEA,VOMITING & HEADACHE.CHRONIC EFFEC
TS:POSS MENTAL CONFUSION,DEPRESSION,FATIGUE,LOSS OF
APPETITE,NAUS,VOMIT,COUGH,LOSS OF SENSE OF BALANCE & VISUAL
DISTURB.
Medical Cond Aggravated by Exposure:N/K
======================= First Aid Measures =======================
First Aid:EYES:IMMED FLUSH W/ LOTS OF COOL H*2O FOR AT LEAST 15 MIN.IF
IRRIT PERSISTS CONT MD.DO NOT WEAR CONTACT LENSES WHILE WORKING W/
PROD.SKIN:PROMPTLY WASH W/ LOTS OF SOAP & H*2O.IF IRRIT
PERSISTS,CONTACT MD.INGEST:INDUCE VOMIT,W/ SYRUP OF IPECAC,IF
AVAIL.GET IMMED MED ATTN.INHAL:REMOVE TO FRESH AIR.IF IRRIT
PERSISTS,CONT MD.NOTE TO MD:TRY TO AVOID EPINEPHRINE & OTHER DRUGS
WHICH BEHAVE SIMILARLY.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:SEE SUPP DATA
Lower Limits:N/K
Upper Limits:N/K
Extinguishing Media:CARBON DIOXIDE,FOAM AND DRY CHEMICAL.
Fire Fighting Procedures:WEAR PRESSURE DEMAND SCBA & FULL PROTECTIVE
EQUIP .KEEP CONTRS COOL.USE SHIELDING TO PROTECT PERSONNEL AGAINST
BURSTING,RUPTURING OR VENTING CONTAINERS.
Unusual Fire/Explosion Hazard:FLAMMABLE.CONTAINERS EXPOSED TO TEMP
ABOVE 120F,49C MAY BURST,RUPTURE OR VENT.BURNING MAY RESULT IN
FORMATION OF HCL,PHOSGENE,CO & CO*2.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF HEAT,SPARKS OR
FLAME.VENTILATE AREA.ABSORB ON INERT OIL ABSORBENT.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:FLAM.HARMFUL OR FATAL IF
SWALLOWED.CONT UNDER PRESS.DO NOT STORE NEAR FLAME,SPARKS,TEMP
>120F,49C OR IN DIRECT SUN.ALWAYS USE ADEQ VENT.(SEE SUPP DA)
Other Precautions:NO SMKG IN AREA.DO NOT USE IN GENL VICIN OF ARC
WELDING,OPEN FLAMES OR HOT SURFACES.HEAT &/OR UV RADIA MAY CAUSE
FORM OF HCL &/OR PHOSGENE .READ & FOLLOW ALL LABEL DIRECTIONS &
PREC BEFORE USE.I NTENDED FOR INDUSTRIAL AND (SEE SUPP DA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Other Protective Equipment:NONE
Work Hygienic Practices:DO NOT WEAR CONTACT LENSES WHILE WORKING WITH
THIS PRODUCT.
Supplemental Safety and Health
% VOLATILES BY WEIGHT:80.FL PT:BELOW 20F (25 INCH FLAME
EXTENSION).HNDLG/STOR PREC:VENT AREA AFTER SPRAYING & BEFORE SMKG
OR WORKING W/ SPARKS OR OPEN FLAME.OTHER PREC:INSTITUTIONAL USE
ONLY.NOT INTEN DED FOR HOUSEHOLD USE OR RESALE.KEEP OUT OF THE
REACH OF CHILDREN.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/K
Vapor Density:N/K
Evaporation Rate & Reference:N/K
Solubility in Water:<1%
Appearance and Odor:AN AEROSOL SPRAY WITH A SOLVENT-LIKE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS,STRONG CAUSTICS AND ACTIVE LIGHT METALS.
Stability Condition to Avoid:EXPOSURE TO HEAT,SPARKS OR FLAME.
Hazardous Decomposition Products:BURNING OF THIS PRODUCT MAY RESULT IN
THE FORMATION OF HCL,PHOSGENE,CO & CO*2.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .DO NOT PUNCTURE OR INCINERATE
CANS.GIVE CONTAINERS TO A DISPOSAL SERVICE EQUIPPED TO SAFELY
HANDLE AND DISPOSE OF PRESSUR IZED CONTAINERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:181-12363,820311,ALKYD METALLIC FINISH
CAGE:DO229
CAGE:18873
CAGE:DO229
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 10%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ALIPHATIC PETROLEUM DISTILLATE
Fraction by Wt: 25%
ACGIH TLV:100 PPM
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 2%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:AROMATIC PETROLEUM DISTILLATE
Fraction by Wt: 17%
ACGIH TLV:100 PPM
Ingred Name:COPPER (SARA III)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 13.1%
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2MG/M3 FUME; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:HEADACHE,NAUSEA,IMPAIRMENT OF REACTION TIME AND
COORDINATION.
======================= First Aid Measures =======================
First Aid:REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEED. SKIN:WASH WITH
SOAP & WATER. EYES:FLUSH WITH WATER 15 MIN. KEEP WARM AND QUIET
!
===================== Fire Fighting Measures =====================
Flash Point:20-73F CC
Lower Limits:1.0
Upper Limits:7.0
Extinguishing Media:CO*2, FOAM, DRY CHEM.
Fire Fighting Procedures:USE H*20 TO COOL EXPD CONTRS. USE SCBA & FULL
PROT.CLTHG.
Unusual Fire/Explosion Hazard:NONE NOTED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES,VENTILATE AREA
WELL.ABSORB WITH VERMICULITE OR OTHER MATERIALS, SUCH AS
SAWDUST,RAGS,PAPER & PLACE IN CLOSED CONTAINER. USE NON SPARKING
TOOLS. WEAR PROPER PROTECTIVE EQUIPMENT DURING CLEAN UP.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM IGNITION SOURCES.KEEP
CONTAINERS CLOSED.DO NOT STORE ABOVE 120F.AVOID PHYSICAL DAMAGE.
Other Precautions:WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING OR
SMOKING.OBSERVE LABEL PRECAUTIONS.CONTAINERS SHOULD BE GROUNDED
WHEN POURING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA RESPIR TC-23C IF AIR CONTAMINANTS
NOT FEASIBLE.
Ventilation:LOCAL EXHAUST TO MAINTN BELOW TLV AND LEL.
Other Protective Equipment:USE APPROPIATE HYGIENE PRACTICES.
Supplemental Safety and Health
NIOSH 6:ZG8000000,SINC,CAS#7440-66-6,1.45%;NIOSH
7:GF8750000,COBALT,CAS#7440-48-4,0.06%,0.1MG/CUM.NIOSH
8:OF7525000,LEAD,CAS#7439-92-1,0.5%,TLV-0.15MG/CUM.(SEE ADD DATA)
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:212-426F
Vapor Pres:10
Vapor Density:3.0
Spec Gravity:0.919
Evaporation Rate & Reference:<1(ETHER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIQUID PAINT WITH CHARACTERISTIC PAINT ODOR.
Percent Volatiles by Volume:74.7
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEN.
Hazardous Decomposition Products:CO,CO*2,OXIDES OF
COPPER,ZINC,COBALT,LEAD,MANGANESE.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:899 7595 STABILIZER AND REPLENISHER MX 1334-3, PART A
Kit Part:Y
Preparer's Name:NONE
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 65-70%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM CITRATE, TRIBASIC
CAS:68-04-2
RTECS #:GE8300000
Fraction by Wt: 15-20%
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMMONIUM CITRATE, DIBASIC (SARA III)
CAS:3012-65-5
Fraction by Wt: 10-15%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:AMMONIA (SARA III)
CAS:7664-41-7
RTECS #:BO0875000
Fraction by Wt: 0.5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:35 PPM STEL
ACGIH TLV:25 PPM/35 STEL; 9394
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS >5000 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: NO SPECIFIC HAZARD KNOWN.
MAY CAUSE TRANSIENT IRRITATION. SKIN: LOW HAZARD FOR RECOMMENDED
HANDLING. INHALATION: EXPECTED TO BE A LOW HAZARD FOR RECOMMENDED
HANDLING. INGESTION: EXPECTED TO BE A LOW INGESTION HAZARD.
CHRONIC: NONE SPECIFIED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION. SKIN: IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: ANY MATERIAL THAT CONTACTS THE EYE SHOULD BE WASHED OUT
IMMEDIATELY WITH WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
SKIN: WASH WITH SOAP AND WATER. GET MEDICAL ATTENTION IF SYMPTOMS
OCCUR. INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR, GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. INGESTION: DRINK 1-2 GLASSES OF
WATER. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL
FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER.
OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT MATERIAL,
THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN SURFACE
THROUGHLY TO REMOVE RESIDUAL C ONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. KEEP
AWAY FROM INCOMPATABLE SUBSTANCES. USE WITH ADEQUATE VENTILATION.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:GOOD GENERAL VENTILATION (10 AIR CHANGES/ HOUR) SHOULD BE
USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS.
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER, WASHING
FACILITIES.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING.
Supplemental Safety and Health
KEY1: N1, THIS ENTRY DESCRIBES PART A, CONCENTRATE, OF A TWO PART KIT.
SEE NSN 6750-00-D00-3354, P/N IND A FOR PART B, CONCENTRATE, DATA.
ALSO SEE NSN 6750-00-D00-3350, P/N IND W FOR THE WORKING SOLUT ION
DATA. THE PART A AND PART B CONCENTRATES MAKE 10 LITRES OF WORKING
SOLUTION.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.19
pH:8.8
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID. ODORLESS.
Percent Volatiles by Volume:65-70
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BASES, SODIUM HYPOCHLORITE (BLEACH), STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:AMMONIA, CHLORAMINE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS. IF PERMITTED, FLUSH TO SEWER WITH LARGE
AMOUNTS OF WATER.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:160 4776 FIXER MX-1626, READY TO USE
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 80-90% %
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMMONIUM THIOSULFATE
CAS:7783-18-8
RTECS #:XN6465000
Fraction by Wt: 10-15% %
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM ACETATE
CAS:127-09-3
RTECS #:AJ4300010
Fraction by Wt: 1-5% %
Other REC Limits:NONE RECOMMENDED
Ingred Name:BORIC ACID
CAS:10043-35-3
RTECS #:ED4550000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG BORATES/M3
ACGIH TLV:5 MG BORATES/M3
Ingred Name:AMMONIUM BISULFITE (CERCLA)
CAS:10192-30-0
RTECS #:WT3595000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): NOT GIVEN
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. MAY CAUSE TRANSIENT EYE IRRITATION. LOW
SKIN CONTACT HAZARD FOR RECOMMENDED HANDLING. EXPECTED TO BE A LOW
INGESTION HAZARD.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMEEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY PRODUCE
HAZARDOUS DECOMPOSTION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER IF ALLOWABLE WITH LARGE AMOUNTS
OF WATER. OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT
MATERIAL, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN
SURFACE TO REMOVE RESIDUA L CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION. WASH
THOROUGHLY AFTER HANDLING. KEEP FROM CONTACT WITH OXIDIZING
MATERIALS. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:KEEP AWAY FROM INCOMPATIBLE MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
================== Physical/Chemical Properties ==================
HCC:C3
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.08-1.09
pH:4.4
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT YELLOW LIQUID, SLIGHT VINEGAR ODOR
Percent Volatiles by Volume:80-90%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BASES, SODIUM HYPOCHLORITE (BLEACH), STRONG OXIDIZING AGENTS, STRONG
ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:AMMONIA, NITROGEN OXIDES, SULFUR
DIOXIDE, CHLORAMINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. MAY REQUIRE NEUTRALIZATION IF PH
< 2.0 OR PH > 12.5. DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE ANDLOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DICOR PRECOAT DICOR SHADING ENL 94745
CAGE:16969
CAGE:16969
============= Composition/Information on Ingredients =============
Ingred Name:CERAMIC FRIT
Fraction by Wt: 100%
ACGIH TLV:10 MG/CUM GLASS DUST
Ingred Name:CERAMIC PIGMENT
Other REC Limits:10 MG/CUM (DUST)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY ALLOW METALS WITHIN FRIT TO BE
LEACHED WHILE IN THE DIGESTIVE TRACT/GLASSY POWDERED MATERIAL
CARRIES WITH IT THE DANGER OF POSSIBLE SILICEOUS (DISEASE OF
LUNGS)-LIKE EFFECTS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:MAY ALLOW METALS WITHIN FRIT TO BE LEACHED
WHILE IN THE DIGESTIVE TRACT/GLASSY POWDERED MATERIAL CARRIES WITH
IT THE DANGER OF POSSIBLE SILICEOUS (DISEASE OF LUNGS)-LIKE
EFFECTS.
Medical Cond Aggravated by Exposure:LUNG DISEASE
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM DUSTY AREA. SKIN: WASH W/SOAP &
WATER. EYES: FLUSH W/WATER FOR AT LEAST 15 MINUTES. CONSULT
PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:NO FIRE HAZARD
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:HANDLE AS NORMAL SOLID WASTE. SCOOP UP & PLACE
IN APPROPRIATELY MARKED CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM FOOD & DRINK. WASH
HANDS BEFORE EATING.
Other Precautions:THIS MATERIAL SHOULD BE HANDLED & USED ONLY IN A
MANNER CONSISTENT W/THE PRODUCT INSTRUCTIONS. EFFORTS SHOULD BE
MADE TO MINIMIZE EXPOSURE & ENCOURAGE GOOD PERSONAL HYGIENE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED FOR DUSTS & MISTS.
Ventilation:USE LOCAL EXHAUST OR OTHER MEANS TO MINIMIZE DUST EXPOSURE.
Work Hygienic Practices:ENCOURAGE GOOD PERSONAL HYGIENE. WASH HANDS
BEFORE EATING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:INSOLUBLE
Appearance and Odor:POWDER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HYDROFLUORIC ACID
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MATERIAL MAY BE DISPOSED OF IN ACCORDANCE
W/FEDERAL, STATE, & LOCAL ENVIRONMENTAL CONTROL REQULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LACTIC ACID,PROD CODE:0194,0196
CAGE:KO674
CAGE:KO674
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:LACTIC ACID
CAS:50-21-5
RTECS #:OD2800000
Fraction by Wt: 80.-90%.
Ingred Name:LACTIC ACID LACTATE
CAS:97-73-4
Fraction by Wt: 10.-20%.
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50(ORAL RAT: 3.73 G/KG) SEE SUPP.DATA
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRITATION OF EYES, SKIN, OR
MOUTH.
Effects of Overexposure:EYES/SKIN: MAY CAUSE SEVERE IRRITATION ON
BURNS; INGEST: MAY CAUSE IRRITATION & BURNING TO MOUTH & STOMACH.
Medical Cond Aggravated by Exposure:NONE IDENTIFIED
======================= First Aid Measures =======================
First Aid:SKIN/EYES:FLUSH W/PLENTY OF WATER FOR 15-MIN. WHILE REMOVING
CONTAMINATED CLOTHING & SHOES.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:EXTINGUISH WITH AGENT SUITABLE FOR SURROUNDING FIRE
Fire Fighting Procedures:WEAR PROPER PROTECTIVE EQUIPMENT & "SCBA
(POSITIVE PRESS. IF AVAIL.)" W/FULL FACEPIECE.; MOVE CONTRS IF W/O
RISK; COOL FIRE-EXPOSED CONTRS. W/WATER.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS EXPOSED TO HEAT MAY
EXPLODE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR "SCBA" & FULL PROTECTIVE CLOTHING. STOP
LEAK IF YOU CAN DO SO W/O RISK. VENTILATE AREA. NEUTRALIZE SPILL
W/SODA ASH OR LIME. WITH CLEAN SHOVEL, CAREFULLY PLACE MATERIAL
INTO CLEAN DRY CONTAINER &COVER. REMOVE FROM AREA. FLUSH SPILL
RESIDUE/H2O.
Neutralizing Agent:SODA ASH OR LIME
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN CORROSION-PROOF AREA. BAKER'S "SAF-T-DATA" STORAGE COLOR CODE:
WHITE (CORROSIVE).
Other Precautions:DANGER! CAUSES BURNS. DO NOT GET IN EYES, ON SKIN, ON
CLOTHING. AVOID BREATHING VAPOR. KEEP IN TIGHTLY CLOSED CONTAINER.
USE W/ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCENTRATION IS HIGH, A DUST/MIST
RESPIRATOR IS RECOMMENDED. IF CONCENTRATION EXCEEDS CAPACITY OF
RESPIRATOR, A SELF-CONTAIN BRE ATHING APPARATUS IS ADVISED.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
VAPOR & MIST LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:AS REQUIRED FOR THE TASK AT HAND TO MINIMIZE
EXPOSURE.
Work Hygienic Practices:DO NOT GET IN EYES,ON SKIN,ON CLOTHING. AVOID
BREATHING VAPOR. USE W/ ADEQUATE VENTILATION. WASH THOROUGHLY AFTER
HANDL
Supplemental Safety and Health
LD50(SCU-MOUSE):4.5 G/KG; HAZ. CODE FOR STORAGE BASED ON LABEL WARNING!
HOWEVER,NOT REGULATED FOR TRANSPORTATION PER MFR'S MSDS.
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:=122.2C, 252.F
Melt/Freeze Pt:=17.8C, 64.F
Spec Gravity:1.25
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS TO YELLOW LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MFR CITES NONE
Stability Condition to Avoid:NONE DOCUMENTED
Hazardous Decomposition Products:MFR CITES NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IAW ALL APPLICABLE FEDERAL, STATE &
LOCAL ENVIRONMENTAL REGULATIONS. EPA HAZ. WASTE #: D002.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ALCOHOL, DENATURED
Preparer's Name:DON POSCHEN
CAGE:0A9L8
Contract Num:SP0450-00-M-SJ43
CAGE:0A9L8
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL
CAS:64-17-5
RTECS #:KQ6300000
= Wt:95.34
Code:F
= Vol:95.2
OSHA PEL:1900 MG/M3;1000 PPM
ACGIH TLV:1880 MG/M3;1000 PPM
Ingred Name:METHANOL
CAS:67-56-1
RTECS #:PC1400000
= Wt:4.66
Code:F
= Vol:4.8
OSHA PEL:260 MG/M3;200 PPM
ACGIH TLV:262 MG/M3;200 PPM
ACGIH STEL:328 MG/M3;250 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-EYES: BELIEVED TO CAUSE MILD EYE
IRRITATION. SKIN: HARMFUL IF ABSORBED THROUGH SKIN. BELIEVED TO BE
SLIGHTLY IRRITATING. RESPIRATORY SYSTEM: OVEREXPOSURE TO MIST OR
VAPORS MAY CAUSE DIZZINESS, D ROWSINESS, HEADACHE, OR NAUSEA.
MASSIVE OVEREXPOSURE MAY CAUSE UNCONSCIOUSNESS. CHRONIC: REPEATED
SKIN CONTACT MAY CAUSE A PERSISTENT IRRITATION OR DERMATITIS.
Explanation of Carcinogenicity:THIS PRODUCT IS NOT CURRRENTLY LISTED AS
A CARCINOGEN BY NTP, OSHA, OR IARC.
Effects of Overexposure:HEADACHE, DIZZINESS, DROWSINESS, NAUSEA,
UNCONSCIOUSNESS, COMA.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH THOROUGHLY WITH WATER FOR AT LEAST 15 MINUTES.
GET MEDICAL ATTENTION. SKIN: WASH EXPOSED AREA WITH SOAP AND WATER.
REMOVE AND CLEAN CONTAMINATED CLOTHING. IF IRRITATION DEVELOPS SEEK
MEDIC AL ATTENTION. INGESTION: CALL A DOCTOR IMMEDIATELY. ONLY
INDUCE VOMITING AS DIRECTED BY A DOCTOR. NEVER GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS OR CONVULSING PERSON. INHALATION: REMOVE TO
FRESH AIR.IF NOT BREATHING, GIVE MOUTH-TO-MOUTH ARTIFICIAL
RESPIRATION. IF BREATHING IS DIFFICULT, QUALIFIED PERSONNEL MAY
ADMINISTER OXYGEN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:=12.2C, 54.F
Autoignition Temp:=385.C, 725.F
Lower Limits:4.3
Upper Limits:19
Extinguishing Media:USE DRY CHEMICAL, FOAM, OR CARBON DIOXIDE. WATER
MAY BE INEFFECTIVE ON THE FLAMES, BUT WATER SHOULD BE USED TO KEEP
FIRE-EXPOSED CONTAINERS COOL.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE ON THE FLAMES, BUT
WATER SHOULD BE USED TO KEEP FIRE-EXPOSED CONTAINERS COOL. IF A
LEAK OR SPILL HAS NOT IGNITED, USE WATER SPRAY TO DISPERSE THE
VAPORS AND TO PROVIDE PROTECT ION FOR THE PERSONS ATTEMPTING TO
STOP THE LEAK.
Unusual Fire/Explosion Hazard:FLAMMABLE! KEEP CONTAINERS TIGHTLY
CLOSED. EXPLOSIVE AIR-VAPOR MIXTURES MAY OCCUR. VAPOR IS HEAVIER
THAN AIR AND MAY TRAVEL CONSIDERABLE DISTANCES TO SOURCES OF
IGNITION AND THEN FLASH BACK. CARBON MO NOXIDE AND CARBON DIOXIDE
MAY BE FORMED ON BURNING.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES INCLUDING
INTERNAL COMBUSTION ENGINES AND POWER TOOLS. VENTILATE AREA. AVOID
BREATHING VAPOR. USE SUPPLIED-AIR MASK FOR LARGE SPILLS OR IN
CONFINED AREAS. CONTAIN SPILL. REMOVE WITH INERT ABSORBENT. AVOID
CONTACT WITH EYES. AVOID ALLOWING PRODUCT FROM ENTERING STREAMS OR
SEWERS. REPORTABLE QUANTITY: 10,000 LBS. RECYCLE SPILL MATERIAL OR
TREAT AS WASTE MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:DANGER! FLAMMABLE! POISON! KEEP AWAY
FROM HEAT, SPARKS AND FLAME. KEEP CONTAINER CLOSED. AVOID CONTACT
WITH EYES AND PROLONGED CONTACT WITH SKIN. USE ONLY IN WELL
VENTILATED AREAS. AVOID PROLONGED BRE ATHING OF VAPOR OR MIST. KEEP
HEAD AWAY FROM CONTAINER WHEN OPENING OR DISPENSING.
Other Precautions:CAUSES MILD IRRITATION TO THE EYES. MAY CAUSE
IRRITATION TO SKIN. WASH THOROUGHLY AFTER HANDLING. DO NOT MIX WITH
OXIDIZERS, NITRIC ACID AND HYDROGEN PEROXIDE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VAPOR, MIST OR DUST IS GENERATED IN EXCESS OF
PERMISSIBLE CONCENTRATIONS, USE RESPIRATOR APPROVED BY MSHA OR
NIOSH.
Ventilation:LOCAL EXHAUST VENTILATION RECOMMENDED.
DISTILLATES REQUIRED.
CONTACT LENSES.
Other Protective Equipment:PROTECTIVE CLOTHING SUCH AS UNIFORMS,
COVERALLS OR LAB COATS SHOULD BE WORN. LAUNDER OR DRY CLEAN WHEN
SOILED. BOOTS RESISTANT TO CHEMICALS AND PETROLEUM DISTILLATES
REQUIRED.
Work Hygienic Practices:AVOID EYE CONTACT. POISON! DANGER! FLAMMABLE!
CAUSES IRRITATION TO EYES AND SKIN. USE ADEQUATE VENTILATION. MAY
BE FATAL OR CAUSE BLINDNESS IF TAKEN INTERNALLY-CANNOT BE MADE
NONPOISONOUS.
Supplemental Safety and Health
NOTE TO PHYSICIAN: ASPIRATION OF THIS PRODUCT DURING INDUCED EMESIS CAN
RESULT IN LUNG INJURY. IF EVACUATION OF STOMACH CONTENTS IS
CONSIDERED NECESSARY, USE METHOD LEAST LIKELY TO CAUSE ASPIRATION,
S UCH AS GASTRIC LAVAGE AFTER ENDOTRACHEAL INTUBATION.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:=64.4C, 148.F
B.P. Text:(148-173F/64-78C)
Vapor Pres:43.9@68F(20C)
Vapor Density:1.60
Spec Gravity:0.795@60F(15.6C)
pH:NO DATA FOUND
Viscosity:N.D.
Evaporation Rate & Reference:5.9 (BU-ACETATE = 1)
Solubility in Water:INFINITE
Appearance and Odor:COLORLESS, CHARACTERISTIC ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTS VIOLENTLY WITH STRONG OXIDIZERS AND STRONG ACIDS.
Stability Condition to Avoid:REACTS VIOLENTLY WITH HEAT.
Conditions to Avoid Polymerization:DOES NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR PLACE IN RCRA PERMITTED WASTE
MANAGEMENT FACILITY. NO WASTE CLASSIFICATION OF PRODUCT HAS BEEN
ESTABLISHED (AS PRESENTLY CONSTITUTED).
=================== MSDS Transport Information ===================
Transport Information:TRANSPORT, HANDLE, AND STORE IN ACCORDANCE WITH
OSHA REGULATION 1910.106 AND APPLICABLE DOT REGULATIONS. GROUND AND
ELECTRICALLY INTERCONNECT CONTAINERS FOR TRANSFER. USE SPARK-PROOF
TOOLS. DOT PROPER SHIPPING NAME: ALCOHOLS, N.O.S. (ETHANOL,
METHANOL), UN 1987, PG I I. DOT HAZARD CLASS (IF APPLICABLE):
FLAMMABLE LIQUID. LABELS NEEDED: FLAMMABLE LIQUID, ARROWS. DOT
SPECIFICATION CONTAINER: I P I. DOT EXEMPTION NUMBER: NOT
APPLICABLE. LIMITED QUANTITY: NOT APPLICABLE. THIS DENATURED
ALCOHOL CANNOT BE SENT THROUGH U.S. MAIL.
===================== Regulatory Information =====================
SARA Title III Information:SECTION 311 HAZARD CATEGORIZATION: ACUTE,
CHRONIC, FIRE. SECTION 313 TOXIC CHEMICALS: METHANOL, CAS#
67-56-1, 4.8 %(VOLUME).
Federal Regulatory Information:THIS PRODUCT IS LISTED ON THE EPA/TSCA
INVENTORY OF CHEMICAL SUBSTANCES.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:TRI-LIKE BRAKE PARTS CLEANER, 522
CAGE:JO735
CAGE:TERAN
CAGE:JO735
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA (PETROLEUM), LIGHT ALKYLATE; (ISOPARAFFINIC
HYDROCARBONS)
CAS:64741-66-8
RTECS #:QK7970000
Fraction by Wt: 60-80%
OSHA PEL:400 PPM (MFR)
ACGIH TLV:400 PPM (MFR)
Ingred Name:ACETONE (SARA 313) (CERCLA)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 10-20%
OSHA PEL:1000 PPM
ACGIH TLV:750PPM/1000STEL;9495
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYLENE CHLORIDE (SARA 313) (CERCLA)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 10-20%
OSHA PEL:500 PPM; Z-2
ACGIH TLV:50 PPM, A2; 9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:CARBON DIOXIDE; (CARBON DIOXIDE PROPELLANT)
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: 01-05%
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM/30000STEL;95
Ingred Name:TOTAL VOLATILE ORGANIC CONTENT: 70%
RTECS #:9999999VO
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:CHLOROCARBON MATERIALS HAVE PRODUCED
SENSITIZATION OF THE MYOCARDIUM TO EPINEPHRINE IN LABORATORY
ANIMALS AND COULD HAVE A SIMILAR EFFECT IN HUMANS. ADRENOMIMETICS
(EG, EPINEPHRINE) MAY BE CONTRA-INDI CATED EXCEPT FOR
LIFE-SUSTAINING USES IN HUMANS ACUTELY/CHRONICALLY EXPOSED TO
CHLOROCARBONS . (EFTS OF OVEREXP)
Explanation of Carcinogenicity:METHYLENE CHLORIDE: IARC MONOGRAPHS
SUPPLEMENT, VOL 7, PG 194, 1987: GROUP 2B. NTP 7TH ANNUAL REPORT ON
(SUPDAT)
Effects of Overexposure:HLTH HAZ: EYES: MAY CAUSE PAIN & MOD IRRIT.
SKIN: FREQUENT/PRLNG CNTCT MAY CAUSE MILD IRRIT. RPTD CNTCT MAY
CAUSE DRYING/FLAKING OF SKIN. INHAL: INHAL OF MIST CAN CAUSE IRRIT
OF NASAL & RESP PASSAGES. ABUSIVE/EXCESSIVE INHAL OF VAPS MAY
CAUSE IRRIT TO THE UPPER RESP TRACT, DIZZ, NAUSEA & OTHER CNS EFTS.
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LARGE AMOUNTS OF COOL RUNNING WATER FOR AT
LEAST 15 MIN WHILE HOLDING UPPER & LOWER LIDS OPEN. IF IRRIT
PERSISTS GET MED ATTN IMMEDIATELY. SKIN: WASH WITH PLENTY OF SOAP &
WATER. IF IRRI T PERSISTS SEEK MEDICAL ATTENTION. INHAL: REMOVE TO
FRESH AIR. SEEK MED ATTN IMMEDIATELY. IF BREATHING STOPS GIVE
ARTIFICIAL RESPIRATION. INGEST: DO NOT INDUCE VOMITING. SEEK MED
ATTN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:19.0F,-7.2C
Extinguishing Media:FOAM, CO*2, DRY MEDIA.
Fire Fighting Procedures:WEAR NIOSH APPROVED PRESSURE DEMAND SCBA AND
FULL PROTECTIVE EQUIPMENT . COOL FIRE EXPOSED CONTAINERS TO PREVENT
RUPTURING.
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE HCL AND PHOSGENE . EXPOSURE TO TEMPERATURE ABOVE 120F MAY
CAUSE BURSTING.
================== Accidental Release Measures ==================
Spill Release Procedures:ALLOW PROPELLANT TO EVAP. MAINTAIN LOC EXHST &
ADEQ VENT. NO SMKNG, KEEP SPKS, HEAT SOURCES & OPEN FLAME FAR AWAY
FROM SPILL/LEAK. COVER W/ABSORB MATL & SWEEP UP. WASH AREA TO PVNT
SLIPPING. DISPOSE O F SOAKED ABSORB MATL I/A/W/FED, STATE, & LOC
LAWS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN. FOR
INDUSTRIAL AND INSTITUTIONAL USE ONLY. STORE IN A COOL, DRY AREA
AWAY FROM HEAT OR OPEN FLAME.
Other Precautions:NO SMOKING IN AREA OR USE. DO NOT USE IN THE GENERAL
VICINITY OF ARC WELDING, OPEN FLAMES OR HOT SURFACES. HEAT AND/OR
UV RADIATION MAY CAUSE THE FORMATION OF HCL AND/OR PHOSGENE . DO
NOT STORE AT TEMPERATURES ABOVE 120F.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NEEDED FOR PROPER USE IN ACCORDANCE WITH
LABEL DIRECTIONS. NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:PROVIDE LOCAL EXHAUST TO KEEP TLV OR SECTION 2 INGREDIENTS
BELOW ACCEPTABLE LIMITS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPEC GRAV: 0.768 @ 75F (H*2O=1). VP: 90 @ 70F PSIG. EXPLAN OF CARCIN:
CARCINOGENS, 1994: ANTICIPATED TO BE CARCINOGEN. ANIMAL: LUNG, LIV,
SALIVARY, MAMMARY GLAND (TUMORS). EFTS OF OVEREXP: INGESTION: CAN
CAUSE GI IRRITATION, NAUSEA, VOMITING & DIARRHEA. ASPIRATION OF
MATL INTO THE LUNGS CAN CAUSE CHEMICAL PNEUMONITIS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:230F,110C
Vapor Pres:SUPDAT
Vapor Density:>1
Spec Gravity:SUPDAT
Solubility in Water:MODERATE
Appearance and Odor:CLEAR COLORLESS LIQUID, MILD SWEET ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS, STRONG ALKALIES OR STRONG
ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:HCL, PHOSGENE . CARBON DIOXIDE, CARBON
MONOXIDE, HYDROGEN CHLORIDE, SMALL AMOUNTS OF PHOSGENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:AERSOL CANS, WHEN EMPTIED AND DEPRESSURIZED
THROUGH NORMAL USE, POSE NO DISPOSAL; HAZARD AND SHOULD BE
RECYCLED. CONSULT FEDERAL, STATE AND LOCAL AUTHORITIES FOR APPROVED
PROCEDURES.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:NOX RUST 509
Preparer's Name:J KUKSUK
CAGE:02847
CAGE:02847
CAGE:0YMU2
CAGE:6X798
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM OIL (SEVERELY SOLVENT REFINED &/OR SEVERELY
HYDROTREATED).
Fraction by Wt: 55-65%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:5 MG/M3
Ingred Name:PETROLEUM HYDROCARBON (PETROLATUM).
CAS:8009-03-8
Fraction by Wt: 25-30%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3 FUMES
Ingred Name:PARAFFIN WAX
CAS:8002-74-2
RTECS #:RV0350000
Fraction by Wt: 3-6%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3 (FUME)
ACGIH TLV:2 MG/M3 (FUME)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EXCESSIVE INHAL MAY PRODUCE
DIZZINESS, NAUSEA, HEADACHE, INCOORDINATION. MAY CAUSE REVERSIBLE
EYE & SKIN IRRIT. PROLONGED SKIN EXPOSURE MAY CAUSE DERMITITIS OR
OIL ACNE. BREATHING MISTS MAY CAU SE DIZZINESS OR PULMONARY IRRIT.
Medical Cond Aggravated by Exposure:EXPOSURE MAY AGGRAVATE PRE-EXISTING
RESPIRATORY OR SKIN PROBLEMS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. CONSULT PHYSICIAN. IF BREATH
DIFFICULT GIVE OXYGEN. NOT BREATH, GIVE ARTIF RESP. EYES: FLUSH
IMMED W/RUNNING WATER >15 MINS. SEEK MED ATTN IMMED. SKIN: WASH
W/SOAP & WATER. REMOVE CONTAM CLOTH/SHOES. INGEST:DONTINDUCE
VOMIT. CALL DR. IF VOMITING SPONTANEOUSLY KEEP HEAD BELOW HIPS TO
PREVENT ASPIRATION OF LIQUID INTO LUNGS.
===================== Fire Fighting Measures =====================
Flash Point:>300F,>149C
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, WATER SPRAY, OR
REGULAR FOAM, FOG.
Fire Fighting Procedures:PRESSURE SCBA/PROTECTIVE CLOTHING. (LIMITED
PROT). EVAC AREA. STAY UPWIND/OUT OF LOW AREA. NOTIFY AUTHORITIES
OF RUNOFF.MOVE CNTNR FROM FIRE AREA IF SAFE.*
Unusual Fire/Explosion Hazard:KEEP AWAY FROM IGNITS. VAPORS MAY TRAVEL
TO IGNIT SOURCE & FLASHBACK. CNTNR MAY EXPLODE IN HEAT/FIRE. VAPOR
EXPLOSION HAZ INDOORS/OUTDOORS/SEWERS.
================== Accidental Release Measures ==================
Spill Release Procedures:SHUT OFF IGNITION SOURCES. NO FLARES, SMOKING,
FLAMES IN HAZARD AREA. STOP LEAK IF SAFE. LG SPILLS: DIKE FAR AHEAD
OF SPILL. SM SPILLS: TAKE UP W/SAND/OTHER NONCOMBUSTIBLE ABSORBENT.
PLACE IN CONTAINE RS FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, WELL VENTILATED AREA.
NO FLAME, SPARK, HOT SURFACES. DONT FLAME CUT/WELD ON/NEAR CNTNR.
EMPTY CNTNRS HAZARDOUS.
Other Precautions:NEVER WEAR CONTAM CLOTHING. LAUNDER BEFORE REWEARING.
DISCARD OIL SOAKED SHOES. WASH W/SOAP/WATER AFTER USE/BEFORE
SMOKING/EATING. AVOID EXCESSIVE SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR FOR ORGANIC VAPOR AND
MIST CONTROL EXPOUSRE WHERE VENTILATION IS INADEQUATE.
Ventilation:GENERAL AND LOCAL EXHAUST.
Other Protective Equipment:IF SPLASHING IS ANTICIPATED, WEAR RUBBER
APRON/BOOTS/OTHER PROTECTIVE EQPMT TO MINIMIZE CONTACT.
Supplemental Safety and Health
* USE WATER ON CNTNR SIDES EXPOSED TO FIRE UNTIL WELL AFTER FIRE IS
OUT. STAY AWAY FROM ENDS OF TANKS. USE UNMANNED HOSE HOLDER/MONITOR
NOZ FOR MASSIVE FIRE IN CARGO AREA. WITHDRAW IMMED IF RISING SOU ND
FROM VENTING SAFETY DEVICE OR DISCOLORATION OF TANK.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:<1
Vapor Density:>1
Spec Gravity:0.9
pH:NA
VOC Grams/Liter:.8
Evaporation Rate & Reference:>1 (BU AC=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DARK AMBER, SOFT WAXY SOLID, PETROLEUM OIL ODOR.
Percent Volatiles by Volume:<0.5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, OXIDIZING AGENTS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF SULFUR, MISC HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH STATE LOCAL AND
FEDERAL REGULATIONS. MATERIALS MAY BECOME A HAZARDOUS WASTE THROUGH
USE. IF PERMITTED, INCINERATION MAY BE PRACTICED.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:00435 DIESEL FUEL 2 (BURNER OIL #2)
Preparer's Name:R.T. RICHARDS
CAGE:7B131
CAGE:COOL1
CAGE:STARE
CAGE:7B131
============= Composition/Information on Ingredients =============
Ingred Name:DIESEL FUEL, ALIPHATIC-NITRO FRACTION: NO CAS NO.
RTECS #:HZ1765000
Fraction by Wt: 100%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS 9.0 ML/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION- NARCOSIS OR
DROWSINESS. EYES- IRRITATION. SKIN- SEVERE IRRITATION. BURNS AND
BLISTERING. INGESTION- IRRITATION, BURNS, BLITERING OF MOUTH,
ESOPHAGUS AND STOMACH. CHRONIC: MANUFACTUR ER STATES POSSIBLE
CANCER OR KIDNEY DAMAGE.
Explanation of Carcinogenicity:MANUFACTURER STATES POSSIBLE CARCINOGEN
FROM "MIDDLE DISTILLATES".
Effects of Overexposure:INHALATION: DIZZINESS, DROWSINESS. EYES:
BURNING SENSATION, REDNESS. SKIN: BURNS, RASH, BLISTERS. INGESTION:
BURNING OF MOUTH AND ESOPHAGUS. NAUSEA, VOMITING, STOMACH PAIN.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS MAY BE
AGGAVATED BY EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRATION. EYES: FLUSH WITH PLENTY OF WATER FOR 15
MINUTES. SEE DOCTOR. SKIN: WASH WITH SOAP AND WATER. INGESTION: DO
NOT INDUCE VO MITING! SEE DOCTOR. SEE DOCTOR IF ANY SYMPTOMS
PERSIST.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:160F,71C
Autoignition Temp:Autoignition Temp Text:500F
Lower Limits:0.52 %
Upper Limits:4.1 %
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, FOAM, OR CARBON DIOXIDE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE GEAR. USE WATER FOG TO COOL FIRE EXPOSED CONTAINERS
AND TO DIPERSE VAPORS.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL. ABSORB ON SUITABLE MATERIAL,
SCOOP UP AND PLACE IN CONTAINER FOR DISPOSAL. VENTILATE AREA. AVOID
BREATHING VAPORS. AVOID ALL PERSONAL CONTACT. USE SELF-CONTAINED
BREATHING APPARATUS IN CONFINED AREA.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HEAT AND IGNITION
SOURCES. HANDLE AND STORE IN ACCORDANCE4 WITH OSHA REG. 1910.106.
Other Precautions:USE ONLY AS A FUEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE SELF-CONTAINED BREATHING APPARATUS IF
PEL/TLV EXCEEDED AS IN A LARGE SPILL OR CONFINED AREA.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:USE GOOD PERSONAL HYGENE. LAUNDER CONTAMINATED
CLOTHING BEFORE REUSE.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS. NOTE TO PHYSICIAN: ASPIRATION OF THIS
PRODUCT DURING INDUCED EMESIS CAN RESULT IN LUNG INJURY. IF E
VACUATION OF STOMACH CONTENTS IS CONSIDERED NECESSARY, USE METHOD
LEAST LIKELY TO CAUSE ASPIRATION.
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:650F,343C
Spec Gravity:0.8521
Viscosity:3.0CST @ 100F
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, BRIGHT LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:HEAT, FLAME AND OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:OXIDES OF CARBON
==================== Disposal Considerations ====================
Waste Disposal Methods:IF DISCARDED IN ORIGINAL FORM, DISPOSE OF AS AN
IGNITABLE MATERIAL (D001) UNDER RCRA. OTHERWISE CONTACT LOCAL
ENVIRONMENTAL MANAGER AND DISPOSE OF IN ACCORDANCE WITH LOCAL,
STATE AND FEDERAL REGULATIO NS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DEX-O-TEX P-61 GROUT POWDER
CAGE:88167
CAGE:88167
============= Composition/Information on Ingredients =============
Ingred Name:PORTLAND CEMENT
CAS:65997-15-1
RTECS #:VV8770000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
===================== Hazards Identification =====================
Effects of Overexposure:EYES:INFLAMM.INHAL:NOSE INFLAM.SKIN:ALKALI
BURNS,DRY SKIN(WET CEMENT).INGEST:CONSTIPATION
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR.EYES:FLUSH W/ PLENTYOF WATER & CALL
MD.SKIN:WASH W/ SOAP & WATER.INGEST:CALL MD
===================== Fire Fighting Measures =====================
Flash Point:N/R PER MFR
Fire Fighting Procedures:NONE PER MFR
Unusual Fire/Explosion Hazard:NONE PER MFR
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP OR VACUUM USING GOOD VENTILATION
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN DRY AREA.WASH THOROUGHLY
AFTER HANDLING.
Other Precautions:PRODUCT WILL HARDEN IF IN CONTACT W/ WATER.
============= Exposure Controls/Personal Protection =============
Ventilation:LOCAL EXHAUST
Other Protective Equipment:CLOTHING TO PROTECT SKIN
Supplemental Safety and Health
MSDS PREP:86056.SPEC DATA:TYPE 2.COLOR:GREEN.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:N/R(SOLID)
Solubility in Water:SLIGHT
Appearance and Odor:GREY POWDER-NO ODOR
Percent Volatiles by Volume:0.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:CONTAMINATION W/ WATER
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN SANITARY LANDFILL IN ACCORDANCE W/
FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:81817, COLOR GUARD TOUGH RUBBER COATING-YEL
Preparer's Name:STEPHEN REPETTO
CAGE:62377
CAGE:62377
============= Composition/Information on Ingredients =============
Ingred Name:BENZIN; (VM&P NAPHTHA)
CAS:8030-30-6
RTECS #:DE3030000
Fraction by Wt: 40-45%
OSHA PEL:300 PPM;400 PPM STEL
ACGIH TLV:300 PPM
Ingred Name:THERMOPLASTIC RUBBER
CAS:66070-58-4
Fraction by Wt: 20-25%
Ingred Name:ETHANE, 1,1,1-TRICHLORO-; (METHYL CHLOROFORM) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 20-25%
OSHA PEL:350 PPM;450 PPM STEL
ACGIH TLV:350 PPM;450 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 10-15%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL,RAT) >5000 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MILD SKIN & EYE IRRIT. TOLUENE
(108-88-3) APPEARS ON THE NAVY LISTING OF OCCUP REPRODUCTIVE
HAZARDS. SEEK CONSULTATIONS FROM APPROP HLTH PROFESSIONALS
CONCERNING LATEST HAZ LIST INFORMATION & SAFE HAN DLING & EXPOSURE
RECOMMENDATIONS . CHLOROCARBON MATLS HAVE PRODUCED SENSIT OF THE
MYOCARDIUM TO (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:EPINEPHRINE IN LAB ANIMALS & COULD
HAVE A SIMILAR EFFECT IN HUMANS. ADRENOMIMETICS. (E.G.,
EPINEPHRINE) MAY BE CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINING USES
IN HUMANS ACUTELY/ CHRONICALLY E XPOSED TO CHLOROCARBONS .
ANESTHESIA, HDCH, NAUS, DIZZ, FATIGUE, DROWSINESS, IRREGULAR
HEARTBEAT, SKIN & EYE IRRIT
Medical Cond Aggravated by Exposure:TOLUENE/1,1,1 TRICHLOROETHANE: EYE,
LIVER, SKIN, HEART, RESPIRATORY, AND CENTRAL NERVOUS SYSTEM
DISEASE, AND ALCOHOLISM.
======================= First Aid Measures =======================
First Aid:INGEST: DO NOT INDUCE VOMITING. KEEP INDIVIDUAL CALM. OBTAIN
MEDICAL ATTENTION. INHAL: REMOVE TO FRESH AIR. IF SYMPTOMS PERSIST,
OBTAIN MEDICAL ATTENTION. ADMINISTER OXYGEN OR ARTIFICIAL
RESPIRATION I F NECESSARY. SKIN: WASH WITH SOAP AND WATER. EYE:
FLUSH AT LEAST 15 MIN WITH WATER. OBTAIN MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:28.0F,-2.2C
Lower Limits:1.1%
Upper Limits:10.5%
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
AND FULL PROTECTIVE EQUIPMENT WHEN CONFRONTED WITH LARGE FIRES.
Unusual Fire/Explosion Hazard:THIS MATERIAL IS FLAMMABLE AND MAY BE
IGNITED BY HEAT, SPARKS, FLAME OR STATIC ELECTRICITY. THERMAL
DECOMPOSITION PRODUCTS MAY INCLUDE HCL AND PHOSGENE .
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION. MAINTAIN ADEQUATE
VENTILATION. SOAK UP WITH AN INERT ABSORBENT. STORE IN A CLOSED
CONTAINER UNTIL DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 120F IN CLOSED CONTAINERS
TO PRESERVE SHELF LIFE. KEEP AWAY FROM EYES. AVOID PROLONGED
BREATHING OF VAPORS OR PROLONGED SKIN CONTACT.
Other Precautions:KEEP AWAY FROM SPARKS, FLAMES, OR HIGH HEAT SOURCES.
DO NOT SMOKE IN AREA OF USE. DO NOT USE IN THE GENERAL VICINITY OF
ARC WELDING, OPEN FLAMES OR HOT SURFACES. HEAT &/OR UV RADIATION
MAY CAUSE THE F ORMATION OF HCL AND/OR PHOSGENE .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED ORGANIC VAPOR CARTRIDGE
RESPIRATOR IF INDICATED.
Ventilation:SUFFICIENT TO MAINTAIN VAPOR CONCENTRATION BELOW TLV.
Other Protective Equipment:IMPERVIOUS CLOTHING OR BOOTS AS NEEDED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:>162F,>72C
Vapor Pres:55 @ 20C
Vapor Density:4.6
Spec Gravity:0.93
Evaporation Rate & Reference:35 (ETHER=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:YELLOW LIQUID, MODERATE ODOR.
Percent Volatiles by Volume:55
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, BASES, OXIDIZING AGENTS, SELECTED AMINES, CHEMICALLY
ACTIVE METALS AND POWDERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OXIDES OF CARBON, POSSIBLY HYDROGEN
CHLORIDE AND CARBONYL CHLORIDE. PHOSGENE .
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE FOLLOWING EPA AND LOCAL REGULATIONS.
DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:C6363-2-3LT
CAGE:01277
CAGE:01277
CAGE:82647
============= Composition/Information on Ingredients =============
Ingred Name:RADIUM 226
===================== Hazards Identification =====================
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
======================= First Aid Measures =======================
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
===================== Fire Fighting Measures =====================
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
================== Accidental Release Measures ==================
======================Handling and Storage ======================
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
SOURCE OF DATA-MIL HANDBOOK 600-1 SEP 76.SAFETY & HEALTH DATA DEVELOPED
BY DGSC-STF.
================== Physical/Chemical Properties ==================
HCC:A2
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-IN ACCORDANCE WITH
DOD REGULATIONS AND FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SPECIALTY PRODUCTS & ADHESIVES, S03103 POLY FILM ADHESIVE
CAGE:DO642
CAGE:DO642
CAGE:09800
============= Composition/Information on Ingredients =============
Ingred Name:PROPANE; VP: 760.0
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 15%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT
Ingred Name:BUTANE; VP: 760.0
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: 15%
OSHA PEL:800 PPM
ACGIH TLV:800 PPM
Ingred Name:HEXANE (N-HEXANE) (CERCLA) VP: 127.0
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: 34%
OSHA PEL:500 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:HEPTANE; VP: 50.0
CAS:142-82-5
RTECS #:MI7700000
Fraction by Wt: 5%
OSHA PEL:500 PPM
ACGIH TLV:400 PPM/500 STEL
Ingred Name:ACETONE (SARA 313) (CERCLA) VP: 180.0
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 12%
OSHA PEL:1000 PPM
ACGIH TLV:750 PPM/1000 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:OTHER PREC: CONSULT NFPA CODE. USE APPRVD BONDING &
GROUNDING PROC. CONTENTS UNDER PRESS. DO NOT PUNCTURE, INCIN (ING
8)
RTECS #:9999999ZZ
Ingred Name:ING 7: OR EXPOSE TO TEMP >120F. HEAT FROM SUNLIGHT,
RADIATORS, STOVES, HOT WATER, & OTHER HEAT SOURCES COULD (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: CAUSE CONTR TO BURST. DO NOT TAKE INTERNALLY. KEEP
OUT OF REACH OF CHILDREN. INTENTIONAL MISUSE BY (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: DELIBERATELY CONC & INHALING CONTENTS CAN BE
HARMFUL/FATAL. THIS COATING MAY CONTAIN MATLS CLASSIFIED (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: AS NUISANCE PARTICULATES WHICH MAY BE PRESENT AT
HAZ LEVELS ONLY DURING SANDING/ABRADING OF DRIED FILM.
RTECS #:9999999ZZ
Ingred Name:RESP PROT: GENERATED FROM THIS PRODUCT, UNDERLYING PAINT,
OR THE ABRASIVE.
RTECS #:9999999ZZ
Ingred Name:VENTILATION: REFER TO OSHA STANDARDS 1910.94, 1910.107,
1910.108.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRIT OF EYES, SKIN & RESP SYS.
MAY CAUSE NERV SYS DEPRESS. EXTREME OVEREXP MAY RSLT IN UNCON &
POSS DEATH. SIGNS & SYMPS OF OVEREXP: HDCH, DIZZ, NAUS, & LOSS OF
COORD ARE INDICATIONS OF EXCESS EXPOS TO VAPS/SPRAY MISTS. REDNESS
& ITCH/BURNING SENSATION MAY INDICATE EYE/EXCESS SKIN EXPOS. (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: CHRONIC: PRLNG OVEREXP TO SOLV INGS
MAY CAUSE ADVERSE EFTS TO LIVER, URINARY, BLOOD-FORMING,
CARDIOVASCULAR, & REPRO SYS. METHYL ETHYL KETONE MAY INCR NERV SYS
EFTS OF OTHER SOLVS. RPTS HAVE ASSOC RPTD & PRLNG OVEREXP TO SOLVS
W/PERM BRAIN & NERV SYS DMG.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM &
QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE. EYES: FLUSH W/LARGE
AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. GET MEDICAL ATTENTION.
INGEST: NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. DO
NOT INDUCE VOMITING. GIVE SEVERAL GLASSES OF WATER. SEEK MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:<0F,<-18C
Lower Limits:1.0%
Upper Limits:19.0%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZ ARE PREF.
WATER MAY BE USED TO COOL CLSD CONTRS (SUP DAT)
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT, ELEC EQUIP, SPKS, &
OPEN FLAME. CLSD CONTRS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
APPLICATION TO HOT SURF REQUIRED SPECIAL PREC.(SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE ONLY W/ADEQ VENT. AVOID BRTHG VAP
& SPRAY MIST. AVOID CONT W/SKIN & EYES. CONTENTS ARE EXTREMELY
FLAMM. KEEP AWAY FROM HEAT, SPKS, & OPEN FLAME.
Other Precautions:VAPS WILL ACCUM READILY & MAY IGNITE EXPLO. DURING
USE & UNTIL ALL VAPS ARE GONE: KEEP AREA VENTILATED; DO NOT SMOKE;
EXTING ALL FLAMES, PILOT LIGHTS, & HEATERS; TURN OFF STOVES, ELEC
TOOLS & APPLIANC ES & ANY OTHER SOURCES OF IGNIT. (ING 7)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERS EXPOS CANNOT BE CONTROLLED BELOW APPLIC
LIMITS BY VENT, WEAR PROPERLY FITTED ORG VAP/PARTICULATE RESP
APPRVD BY NIOSH FOR PROT. WHEN SANDING/ABRADING DRIED FILM, WEAR
DUST/MIST RESP APPRVD BY NIOSH FOR DUST WHICH MAY BE (ING 12)
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF
EXPOSURE IS MAINTAINED BELOW APPLICABLE EXPOSURE LIMITS.(ING 13)
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC: TO PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN
EXPOSED TO EXTREME HEAT. EXPLO HAZ: DURING EMER CNDTNS OVEREXP TO
DECOMP PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE IMMED APPARENT.
OBTAIN MED ATTN. SPILL PROC: DEPRESSURIZE CONTR. DISP OF I/A/W FED,
STATE & LOC REGS REGARDING POLLUTION.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:<0F,<-18C
Vapor Density:HVR/AIR
VOC Grams/Liter:3.93
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MAY BE HAZ AS DEFINED UNDER RCRA 40 CFR
261. WASTE MUST BE TESTED FOR IGNITABILITY TO DETERMINE APPLIC EPA
HAZ WASTE NUMBERS. WASTE FROM PRODS CONTAINING METHYL ETHYL KETONE
MAY ALSO REQUIRE TES TING FOR EXTRACTABILITY. DO NOT INCIN. (SUP
DAT)
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:896 SPRED URETHANE FLOOR ENAMEL
CAGE:EO700
CAGE:72818
CAGE:EO700
============= Composition/Information on Ingredients =============
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE (IARC - GROUP 3) *98-3*
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 5-10%
OSHA PEL:2 MG/CUM (RESP DUST)
ACGIH TLV:2 MG/CUM (RESP DUST)
Ingred Name:KEROSENE (PETROLEUM), (C10-C15 SATURATED HYDROCARBONS 97%,
C10 AROMATICS 3%) (SUSP ANIMAL CARCINOGEN BY IARC)*98-3*
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 40-50%
Other REC Limits:200 PPM EXXON
Ingred Name:SOYBEAN OIL, POLYMER W/PENTAERYTHRITOL, TDI & TUNG OIL
*98-3*
CAS:67989-28-0
Fraction by Wt: 10-20%
Ingred Name:RED IRON OXIDE/IRON (III) OXIDE/FERRIC OXIDE/YELLOW FERRIC
OXIDE/YELLOW IRON OXIDE/IRON OXIDE PIGMENT
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 1-5%
OSHA PEL:10 MG/CUM
ACGIH TLV:5 MG/CUM (FE)
Ingred Name:YELLOW OXIDE, YELLOW IRON OXIDE*98-3*
CAS:51274-00-1
Fraction by Wt: 5-10%
Ingred Name:VOLATILE ORGANIC CONTENT: 8.5 LBS/GAL
RTECS #:9999999VO
Ingred Name:FATTY ACIDS, TALL-OIL, POLYMER W/GLYCEROL, PENTAERYTHRITOL
& PHTHALIC ANHYDRIDE *98-3*
CAS:66070-62-0
Fraction by Wt: 20-30%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY TRACT
IRRITANT. CNS DEPRESSION/ANESTHETIC EFFECT. SKIN:
IRRITATION/DERMATITIS. EYES: SEVERE IRRITANT, BLURRED VISION.
INGESTION: LARGE AMOUNTS CAUSE LUNG INFLAMMATION & DAMAGE DUE TO
ASPIRATION. REPEATED/PROLONGED OVEREXPOSURE TO SOLVENT MAY CAUSE
PERMANENT BRAIN/NERVOUS SYSTEM DAMAGE. (SEE SUPP
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, FATIGUE, DROWSINESS, DIZZINESS,
LIGHTHEADEDNESS, HEADACHE, UNCOORDINATION, NAUSEA, NARCOSIS,
DEFATTING OF SKIN, BLURRED VISION, TEARING, REDNESS, INFLAMMATION
Medical Cond Aggravated by Exposure:PREEXISTING EYE, SKIN, RESPIRATORY
& LUNG DISORDERS, ASTHMA-LIKE CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED
BREATHING. HAVE TRAINED PERSON GIVE OXYGEN IF NEEDED. SKIN: WASH
OFF QUICKLY W/PLENTY OF WATER, THEN SOAP & WATER. EYES: FLUSH
IMMEDIATELY W/LARGE AMOUNTS OF WATER FOR 15 MINS. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:105F
Lower Limits:0.7
Extinguishing Media:DRY CHEMICAL/FOAM
Fire Fighting Procedures:WATER MAY BE USED TO COOL & PROTECT EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT/FIRE. VAPORS CAN FORM EXPLOSIVE MIXTURES IN
AIR AT ELEVATED TEMPS. EMITS TOXIC GASES UNDER FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. VENTILATE
AREA. MAY BE COLLECTED W/NONCOMBUSTIBLE ABSORBENT MATERIALS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 100F. KEEP AWAY FROM HEAT,
SPARKS & OPEN FLAME. KEEP CONTAINERS TIGHTLY CLOSED & UPRIGHT WHEN
NOT IN USE. USE ONLY W/ADEQUATE VENTILATION.
Other Precautions:GROUND EQUIPMENT WHEN TRANSFERRING TO PREVENT
ACCUMULATION OF STATIC CHARGE. DON'T TAKE INTERNALLY. KEEP OUT OF
REACH OF CHILDREN. AVOID CONTACT W/SKIN & EYES & BREATHING OF
VAPORS. EMPTY CONTAINERS M AY CONTAIN HAZARDOUS RESIDUES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE ONLY NIOSH/MSHA APPROVED RESPIRATORS
IAW/OSHA STANDARD 29 CFR 1910.134. IF SANDING IS DONE, WEAR A DUST
MASK TO AVOID BREATHING OF SANDING DUST.
Ventilation:DILUTION/LOCAL EXHAUST TO PREVENT BUILDUP OF VAPORS.
Other Protective Equipment:EYE WASH, SAFETY SHOWER
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING & INHALING THE
CONTENTS MAY BE HARMFUL/FATAL.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:310-400F
Percent Volatiles by Volume:53.2
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, BASES, AMINES
Stability Condition to Avoid:EXTREME HEAT/FIRE/OPEN
FLAMES/SPARKS/ELEVATED TEMPERATURES.
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS. UN1263
COMBUSTIBLE LIQUID.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:2,4-D LOW VOLATILE ESTER
CAGE:1E922
CAGE:1E922
============= Composition/Information on Ingredients =============
Ingred Name:2,4-D ESTERS (SARA III)
CAS:25168-26-7
RTECS #:AG8575000
Fraction by Wt: 67.2%
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:N-BUTYL ALCOHOL (SARA III)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: <0.525%
Other REC Limits:300 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:KEROSENE, KEROSINE
CAS:8008-20-6
RTECS #:OA5500000
Fraction by Wt: 29.3%
Other REC Limits:100 MG/CUM NIOSH
Ingred Name:EMULSIFYING AGENT
Fraction by Wt: <2.975%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION. INGESTION: HARMFUL,
& TOXIC. INHALATION: MODERATE WEAKNESS, LETHARGY, & ANOREXIA.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: IRRITATION. INGESTION: TOXIC, & HARMFUL.
INHALATION: MODERATE WEAKNESS, LETHARGY, & ANOREXIA.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/WATER. INGESTION: DON'T INDUCE VOMITING.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:146F
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:USE WATER SPRAY TO KEEP FIRE-EXPOSED
CONTAINERS COOL. EXCESS WATER WILL DILUTE & SPREAD PESTICIDE.
Unusual Fire/Explosion Hazard:COMBUSTIBLE LIQUID
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILLS. CLEAN UP & ABSORB MATERIAL
W/DRY GRANULES OR SAND. REMOVE AS MUCH AS POSSIBLE. PLACE IN A
CLOSED MARKED CONTAINER IN SECURED BUILDING FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM CHILDREN. AVOID CONTACT
W/SKIN, EYES OR CLOTHING. DON'T STORE NEAR FERTILIZERS, SEEDS,
INSECTICIDES OR FUNGICIDES.
Other Precautions:AVOID INHALING OF VAPOR OR SPRAY MISTS. EXCESS WATER
WILL DILUTE & SPREAD PESTICIDE. USE ONLY AS DIRECTED ON LABEL. READ
PRECAUTIONS ON PRODUCT LABEL BEFORE USING OR HANDLED. AVOID MISTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR FOR MISTS,
PESTICIDE/ORGANIC VAPOR.
Ventilation:LOCAL EXHAUST: REDUCE MISTS
Other Protective Equipment:PROTECTIVE COVERALLS, RUBBER SPLASH APRON
Work Hygienic Practices:WASH ALL CLOTHING & EXPOSED SKIN AFTER USING
ANY PESTICIDE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:350F
Melt/Freeze Pt:M.P/F.P Text:LIQUID
Spec Gravity:1.032
Solubility in Water:EMULSIFIABLE
Appearance and Odor:AMBER LIQUID, W/AROMATIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT & FIRE
Hazardous Decomposition Products:NOXIOUS FUMES, HYDROGEN CHLORIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE IS TOXIC. DISPOSE OF IN ACCORDANCE W/ALL
FEDERAL, STATE & LOCAL REGULATIONS. CONCERNING HEALTH & POLLUTION.
COMBUSTIBLE LIQUID.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SODIUM CHLORIDE
CAGE:66372
CAGE:66372
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM CHLORIDE
CAS:7647-14-5
RTECS #:VZ4725000
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 3,000 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. INHALATION: HARMFUL
& IRRITATION TO MUCOUS MEMBRANES & UPPER RESPIRATORY TRACT. SKIN:
HARMFUL IF ABSORBED & IRRITATION. INGESTION: HARMFUL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION. SKIN: HARMFUL IF ABSORBED &
IRRITATION. INHALATION: HARMFUL & IRRITATION TO MUCOUS MEMBRANES &
UPPER RESPIRATORY TRACT. INGESTION: HARMFUL.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/COPIOUS AMOUNTS OF WATER FOR AT
LEAST 15 MINS. SKIN: IMMEDIATELY WASH W/SOAP & WATER COPIOUS
AMOUNTS OF WATER. INHALATION: REMOVE TO FRESH AIR. IF NECESSARY,
GIVE ARTIFICIAL RESPIRATION, PREFERABLY MOUTH-TO-MOUTH,& OXYGEN.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NON-COMBUSTIBLE
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE CONDITIONS.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:REACTS VIOLENTLY W/BROMINETRI-FLUORIDE &
LITHIUM.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. SWEEP UP/PLACE IN
BAG/HOLD WASTE DISPOSAL. AVOID RAISING DUST. VENTILATE AREA/WASH
AFTER MATERIAL PICKUP IS COMPLETE. HYDROLYSIS/NEUTRALIZATION
REACTIONS MAY GENERATE HEAT/F UMES WHICH CAN BE CONTROLLED BY
ADDITION RATE.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID INHALATION OF DUST. AVOID
CONTACT W/EYES, SKIN, & CLOTHING. KEEP CONTAINER TIGHTLY CLOSED.
THIS PRODUCT IS HYGROSCOPIC.
Other Precautions:STORE IN A COOL DRY PLACE. AVOID RAISING DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:REQUIRED
Ventilation:MECHANICAL EXHAUST: REQUIRED
Other Protective Equipment:SAFETY SHOWER, EYE BATH, RUBBER BOOTS
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:1473.8F
Vapor Density:2.161
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:TOXIC FUMES
==================== Disposal Considerations ====================
Waste Disposal Methods:CAUTIOUSLY ADD TO LARGE STIRRED EXCESS OF WATER.
ADJUST PH TO NEUTRAL, SEPARATE ANY INSOLUBLE SOLIDS/LIQUIDS &
PACKAGE FOR HAZARDOUS-WASTE DISPOSAL. FLUSH AQUEOUS SOLUTION DOWN
DRAIN W/PLENTY OF WATER ACCORDING TO FEDERAL/LOCAL/STATE
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:WECK INSTRUMENT CLEANER POWDER-850103
CAGE:18916
CAGE:18916
============= Composition/Information on Ingredients =============
Ingred Name:INORGANIC CLEANING AGENTS
Ingred Name:ORGANIC SURFACTANTS
Ingred Name:CHELATES CORROSION INHIBITORS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-EYES/SKIN:IRRITATION.
INGEST:GASTRO-INTESTINAL TRACT IRRITATION.
Explanation of Carcinogenicity:NONE OF THE CHEMICALS IN THIS PRODUCT IS
LISTED BY IARC, NTP OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYE:IRRITANT SKIN:LOCAL IRRITATION.
INGEST:IRRITATION TO GASTRO-INTESTINAL TRACT.
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:FIRST AID-EYE:FLUSH WITH WATER FOR 15 MINUTES. SEE DOCTOR
SKIN:WASH WITH MILD SOAP AND WATER. INHALATION:REMOVE TO FRESH AIR.
SEE DOCTOR. INGESTION:GIVE LARGE AMOUNTS OF WATER. INDUCE VOMITING.
CONSUL T DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NONE REQUIRED
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SPILL-COLLECT AND FLUSH WITH WATER.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE-KEEP CONTAINER CLOSED WHEN NOT
IN USE.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Ventilation:NONE REQUIRED
Other Protective Equipment:NONE
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING OR DRINKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NONE.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:SOLID
Melt/Freeze Pt:M.P/F.P Text:230F,110C
Spec Gravity:SOLID
pH:8.5-9
Solubility in Water:COMPLETE
Appearance and Odor:GREEN POWDER.NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LIM - LIQUID ICE MACHINE CLEANER 13 OZ BOTTLE
Preparer's Name:TIM HEATON
CAGE:ACESU
CAGE:ACESU
============= Composition/Information on Ingredients =============
Ingred Name:PHOSPHORIC ACID
CAS:7664-38-2
RTECS #:TB6300000
Fraction by Wt: >50%
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/CUM
ACGIH TLV:1 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CORROSIVE. CAUSES BURNS TO EYES, SKIN
& RESPIRATORY TRACT. INHALATION: IRRITATION OF NOSE & THROAT.
SKIN/EYES: BURNING & IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, BURNING, GASTRIC DISTRESS.
======================= First Aid Measures =======================
First Aid:EYES: WASH W/PLENTY OF WATER FOR 15 MINS. SKIN: WASH WELL
W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION: DRINK
WATER. DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL, WATER FOG, CO2
Fire Fighting Procedures:WEAR SCBA.
Unusual Fire/Explosion Hazard:REACTS W/OXIDIZERS, CHLORINATING AGENTS &
MOST METALS.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: DILUTE & WASH TO DRAIN. LARGE: CAN'T
OCCUR.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:KEEP THIS & ALL CHEMICALS OUT OF REACH OF CHILDREN.
AVOID CONTACT W/EYES & SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NEEDED IN MISTING APPLICATION TO KEEP TLV BELOW
LIMITS.
Ventilation:LOCAL EXHAUST VENTILATION.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:275F
Vapor Pres:15
Vapor Density:>1
Spec Gravity:1.4
Evaporation Rate & Reference:(WATER =1): >1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIQUID W/NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALINE & ALKALINE MATERIALS, OXIDIZERS, CHLORINATING AGENTS, METALS.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DEPOSIT IN LAND FILL IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: MARINE PREMIUM FILLER, 46005/QUART
Cage: 1BY21
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 76381
Cage: 1BY21
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: YES
OSHA: NO
Effects of Exposure: ACUTE: EYES: MOD IRRIT INCL REDNESS, SWELL, PAIN, TEARING,
& HAZY VISION. SKIN: MILD IRRIT (AFTER PRLNG/RPTD CONT) INCL REDNESS,
SWELL, & ITCH. MAY BE ABSORBED THRU SKIN & PRDCE EFTS SIMILAR TO
THOSE CAUSED BY INHAL &/OR INGEST. INHAL: CNSDEPRESS INCL HDCH, DIZZ,
DROW, INCOORD, SLOWED RXN TIME, (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: USERS OF THE "L" VERSION OF SHOULD CONSULT
"LR" VERSION (INGREDIENT 11) FOR ADDITIONAL INFORMATION (FP N).
Signs And Symptions Of Overexposure: HLTH HAZ: SLURRED SPEECH, GIDD &
UNCON. IRRIT (UPPER RESP) INCL SORENESS OF NOSE & THROAT, COUGHING &
SNEEZING. DUST FROM CUTTING, GRINDING, SANDING/MACHINING MAY CAUSE IRRIT OF
RESP SYS. WHILE THE FO LLOWING EFTS ARE ASSOC W/ONE OR MORE OFINDIVIDUAL INGS
IN THIS PROD & ARE REQUIRED TO BE INCLUDED ON MSDS BY (SUP DAT)
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. GET
IMMEDIATE MEDICAL ATTENTION. SKIN: FLUSH WITH LARGE AMOUNTS OF WATER. IF
IRRITATION PERSISTS, GET MEDICAL ATTENTION. INHALATION: IF SIGNS/SYMPTOMS
OCCUR, REMOVE PERSON TOFRESH AIR. IF SIGNS/SYMPTOMS CONTINUE, CALL MD.
INGESTION: DO NOT INDUCE VOMITING. DRINK TWO GLASSES OF WATER. CALL MD.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REFER TO OTHER SECTIONS OF MSDS FOR INFO REGARDING
PHYSICAL & HLTH HAZS, RESP PROT, VENT, & PERS PROT EQUIP. VENT AREA.
EXTING ALL IGNIT SOURCES. EVACUATE UNPROT PERS FROM HAZ AREA. COVER W/ABSORB
MAT L. COVER SPILL AREA W/LIGHT WATER BRAND
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: INCIN IN PERMITTED HAZ WASTE INCIN. SINCE REGS VARY,
CONSULT APPLIC REGS/AUTH BEFORE DISP. IN EVENT OF UNCONTROLLED RELEASE, USER
SHOULD DETERMINE IF RELEASE QUALIFIES AS REPORTABLE QTY. U.S. EPA HAZ WASTE
NUMBER: D001 (IGNITABLE)
Handling And Storage Precautions: AVOID EYE CONTACT. AVOID PROLONGED OR
REPEATED SKIN CONTACT. DO NOT INGEST. DO NOT INGEST. STORE AWAY FROM HEAT.
STORE OUT OF DIRECT SUNLIGHT.
Other Precautions: KEEP CONTAINER CLOSED WHEN NOT IN USE. KEEP OUT OF THE REACH
OF CHILDREN. KEEP CONTAINER TIGHTLY CLOSED. FLAMMABLE LIQUID AND VAPOR. KEEP
AWAY FROM HEAT, SPARKS, OPEN FLAME, AND OTHER SOURCES OF IGNIT ION.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: 88.0F,31.1C
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, ALCOHOL-RESISTANT
FOAM.
Fire Fighting Procedures: WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N).
=======================================================
Control Measures
=======================================================
Respiratory Protection: AVOID BREATHING OF VAPORS. AVOID BREATHING OF DUST
CREATED BY CUTTING, SANDING/GRINDING. SELECT ONE OF THE FOLLOWING NIOSH
APPROVED RESPIRATORS BASED ON AIRBORNE CONCENTRATION OF CONTAMINANTS &
I/A/W OSHA REGULATIONS: HALF-MASK DUST RESP.
Ventilation: PROVIDE APPROP LOCAL EXHAUST FOR GRINDING, CUTTING/SANDING CURED
MATERIAL. USE IN WELL-VENTILATED AREA.
Other Protective Equipment: EMERGENCY EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: USERS OF "L" VERSION OF SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). EFTS OF OVEREXP: U.S. OSHA HAZ COMMUNICATION
STD, THEY ARE NOT EXPECTED EFTS DURING FORESEEABLE USE OF THIS PROD: INGEST
MAY CAUSE ASPIR PNEUMIT INCL COUGH, DFCLT BRTHG, WHEEZING, COUGHING UP BLOOD
& PNEUM, WHICH CAN BE FATAL.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 293F,145C
Vapor Pres: SEE ING 2
Vapor Density: SEE ING 2
Spec Gravity: 1.14 (H*2O=1)
Solubility in Water: NIL
Appearance and Odor: LIGHT YELLOW PASTE WITH STYRENIC ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: STORAGE AT ELEVATED TEMPERATURES WILL SHORTEN
SHELF LIFE.
Materials To Avoid: STRONG ACIDS, STRONG BASES, STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: CARBON MONOXIDE AND CARBON DIOXIDE,
HYDROCARBONS, TOXIC VAPORS, GASES OR PARTICULATES.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: MARINE PREMIUM FILLER, 46005/QUART
Cage: 1BY21
Company Name: MINNESOTA MINING AND MFG CO ENGINEERING DOCUMENT SYSTEMS DIV
Street: 3M CTR
Zipcode: 55144-1000
Label Required IND: Y
Date Of Label Review: 08/21/1998
Status Code: C
Label Date: 08/21/1998
Origination
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Severe
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE. ACUTE: EYES: MODERATE IRRIT INCL REDNESS,
SWELLING, PAIN, TEARING, & HAZY VISION. SKIN: MILD IRRIT (AFTER
PROLONGED/REPEATED CONT) INCL REDNESS, SWELL, & ITCH. MAY BE ABSORBED
THROUGH SKIN& PRODUCE EFFECTS SIMILAR TO THOSE CAUSED BY INHAL &/OR
INGEST. INHAL: CNS DEPRESSION INCL HEADACHE, DIZZ, DROW, INCOORDINATION,
SLOWED REACTION TIME, SLURRED SPEECH, GIDDINESS & UNCONSCIOUSNESS. IRRI
T; SORE NOSE & THROAT, COUGHING, SNEEZING. INGEST: POSS ASPIR HAZ-ASPIR
PNEUMONITIS; COUGH, DIFFICULTY BREATHING, WHEEZING, COUGHING UP BLOOD &
PNEUMONIA, CAN BE FATAL. CHRONIC: CANCER HAZ. CONTAINS M ATL LISTED AS ANIMAL
NERVOUS SYSTEM CARCIN (FP N).
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:UNIONMELT SUBMERGED ARC WELDING FLUXES, FUSED 101
Resp. Party Other MSDS Num.:7960-E
CAGE:84021
CAGE:84021
CAGE:HO829
============= Composition/Information on Ingredients =============
Ingred Name:MANGANESE OXIDE (MNO)
CAS:1344-43-0
RTECS #:OP0900000
= Wt:4.
OSHA PEL:5 RESPIRABLE
ACGIH TLV:10 MG/M3 OXIDE FUME
Ingred Name:ALUMINUM OXIDE (AL2O3)
CAS:1344-28-1
RTECS #:BD1200000
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:SILICA, CRYSTALLINE QUARTZ; (SILICA, USE QUARTZ FORMULA)
CAS:14808-60-7
RTECS #:VV7330000
OSHA PEL:see Table Z-3
ACGIH TLV:0.1 MG/M3
Ingred Name:CALCIUM OXIDE (CAO)
CAS:1305-78-8
RTECS #:EW3100000
OSHA PEL:5 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:MAGNESIUM OXIDE (MGO)
CAS:1309-48-4
RTECS #:OM3850000
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:IRON; (IRON OXIDES)
CAS:7439-89-6
RTECS #:NO4565500
OSHA PEL:10 MG/M3 TOTAL PART
ACGIH TLV:5 MG/M3 (OXIDE FUME)
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:CALCIUM DIFLUORIDE ; (FLUORSPAR)
CAS:7789-75-5
RTECS #:EW1760000
OSHA PEL:2.5 MG/M3 AS F
ACGIH TLV:2.5 MG/M3 AS F
Ingred Name:CRYOLITE (NA3(ALF6)) (SODIUM ALUMINUM FLUORIDE)
CAS:15096-52-3
RTECS #:WA9625000
OSHA PEL:2.5 MG/M3 AS F
ACGIH TLV:2.5 MG/M3 AS F
Ingred Name:BARIUM OXIDE (BAO)
CAS:1304-28-5
RTECS #:CQ9800000
= Wt:12.
OSHA PEL:0.5 MG/M3 SOL BA
ACGIH TLV:0.5 MG/M3 SOL BA
Ingred Name:ZIRCONIUM; (ZIRCONIUM COMPOUNDS ZRO2)
CAS:7440-67-7
RTECS #:ZH7070000
OSHA PEL:5 MG/M3 RESP
ACGIH TLV:5 MG/M3
ACGIH STEL:10 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ELEC ARC WORKING MAY CREATE ONE OR
MORE OF FOLLOWING: FUMES & GASES CAN BE DANGEROUS TO HLTH. ELEC
SHOCK CAN KILL. ARC RAYS CAN INJURE EYES & BURN SKIN. NOISE CAN DMG
HEARING. ADDNL DETAILED DESCRIPTI ON OF HLTH & PHYSICAL HAZS &
CONSEQUENCES MAY BE FOUND IN ESAB'S PUB F52-529 "PRECS & SAFE
PRACTS FOR ELEC WELDING & CUTTING" & F2035, "PRESC & SAFE PRACTS
FOR GAS WELDING, CUTTING & HEATING." MAY BE OBTAINED FROM LOC
SUPPLIER/WRITING MFR. ACUTE: FUME & DUST OVEREXP MAY INCL IRRIT OF
EYES, LUNGS, NOSE & THROAT. SOME TOX GASES ASSOC W/WELDING MAY
CAUSE PULM EDEMA, ASPHY & DEATH. ACUTE OVEREXP MAY I NCL SIGNS &
SYMPS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ: IARC
MONOGRAPHS, VOL 68, 1997: GROUP 1. NTP 7TH ANNUAL REPORT ON
CARCINOGENS, 1994:ANTICIPATED CARCINOGEN.
Effects of Overexposure:HLTH HAZS: SUCH AS WATERY EYES, NOSE & THROAT
IRRIT, HDCH, DIZZ, DFCLTY BRTHG, FREQUENT COUGH OR CHEST PAIN. DUST
GENERATED FROM POURING/OTHERWISE HNDLG FLUX MAY ALSO CAUSE IRRIT OF
EYES, LUNGS, NOSE & THROAT. INGEST OF BARIUM OXIDE CAN RSLT IN SEV
PAIN, VOMIT, PARALYSIS & DEATH. CHRONIC OVEREXP TO AIR CONTAMINANTS
MAY LEAD TO THEIR ACCUM IN LUNGS, CNDTN WHICH MAY BE SEEN AS DENSE
AREAS ON CHEST X -RAYS. SEVERITY OF CHG IS PROPORTIONAL TO LENGTH
OF EXPOS. CHGS SEEN ARE NOT NECESSARILY ASSOC W/SYMPS OR SIGNS OF
REDUCED LUNG FUNC/DISEASE. IN ADDN, X-RAY CHGS MAY BE CAUSED BY
NON-WORK FACTORS SUCH AS SMKNG, ETC. (SUPDAT)
Medical Cond Aggravated by Exposure:INDIVIDUALS W/ALLERGIES OR IMPAIRED
RESP FUNC MAY HAVE SYMPS WORSENED BY EXPOS TO WELDING FUMES.
HOWEVER, SUCH RXN CANNOT BE PREDICTED DUE TO VARIATION IN
COMPOSITION & QTY OF DECOMP PRODS.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMEDIATELY . EYES: IMMEDIATELY FLUSH EYES
W/POTABLE WATER FOR AT LEAST 15 MINUTES. SEEK ASSISTANCE FROM MD .
SKIN: FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD . IN CA SE OF EMER,
CALL FOR MED AID. EMPLOY FIRST AID TECHNIQUE RECOM BY RED CROSS. IF
BRTHG IS DFCLT, GIVE OXYG & CALL MD. FOR ELEC SHOCK, DISCONNECT &
TURN OFF POWER. IF NOT BRTHG, BEGIN ARTF RESP, PREF MO
UTH-TO-MOUTH. IF NO DETECTABLE PULSE, BEGIN CPR. IMMED CALL MD. FOR
ARC BURN, APPLY COLD, CLEAN COMPRESSES & CALL MD.
===================== Fire Fighting Measures =====================
Extinguishing Media:PRODUCT WILL NOT BURN. HOWEVER, WELDING ARCS & SPKS
CAN IGNITE COMBUSTIBLE & FLAMMABLE MATERIALS. USE EXTINGUISHING
MEDIA RECOMMENDED FOR BURNING MATERIALS & FIRE SITUATION.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:SEE ANSI Z49.1 "SAFETY IN WELDING &
CUTTING" & "SAFE PRACTICES" CODE: SP, PUBLISHED BY AMERICAN WELDING
SOCIETY, PO BOX 351040, MIAMI, FL 33135 & NFPA 51B "CUTTING &
WELDING PROCESSES," PUBLISHED BY N FPA, BATTERYMARCH PARK, QUINCY,
MA 02269FOR ADDITIONAL FIRE PREVENTION & PROTECTION INFO.
======================Handling and Storage ======================
Handling and Storage Precautions:READ & UNDERSTAND MFR'S INSTRUCTIONS &
PRECAUTIONARY LABEL ON PRODUCT. SEE ANSI Z-49.1, "SAFETY IN WELDING
& CUTTING," PUBLISHED BY AMERICAN WELDING SOCIETY, PO BOX 351040,
MIAMI, FL 33135 & OSHA PUBL ICATION 2206 (29 CFR 1910), US
GOVERNMENT PRINTING OFFICE, WASHINGTON, DC 20402 FOR MORE DETAILS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRABLE FUME RESPIRATOR OR
AIR SUPPLIED RESPIRATOR WHEN WELDING IN CONFINED SPACE OR WHERE
LOCAL EXHAUST OR VENTILATION DOES NOT KEEP EXPOSURE BELOW TLV.
Ventilation:USE ENOUGH VENT, LOC EXHST AT ARC OR BOTH, TO KEEP FUMES &
GASES BELOW TLV'S IN WORKER'S BRTHG ZONE & GEN AREA. TRAIN WELDER
TO KEEP HIS/HER HEAD OUT OF FUMES.
Other Protective Equipment:WEAR HEAD, HAND & BODY PROT WHICH HELP PVNT
INJURY FROM RADIA, SPKS & ELEC SHOCK. SEE ANSI Z49.1. AT MINIMUM,
APRONS, HATS, (OTHER INFO)
Supplemental Safety and Health
EFTS OF OVEREXP: CHRONIC FLUORIDE ABSORPTION CAN CAUSE SCLEROSIS OF
BONES & MOTTLED TEETH. OVEREXP TO MANGANESE CMPDS MAY AFFECT CNS,
SYMPS OF WHICH ARE LANGOUR, SLEEPINESS, MUSC WEAK, EMOTIONAL DISTU
RBS & SPASTIC GAIT. OVEREXP TO RESPIRABLE CRYSTALINE SILICA MAY
RSLT IN SILICOSIS, A DISABLING LUNG DISEASE.
================== Physical/Chemical Properties ==================
Appearance and Odor:FUSED FLUXES ARE GRANULATED GLASS-LIKE PARTICLES,
ODORLESS. BONDED (OTHER INFO)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE CURRENTLY KNOWN.
Hazardous Decomposition Products:WELDING FUMES & GASES CANNOT BE
CLASSIFIED SIMPLY. COMPOSITION & QTY OF BOTH DEPEND ON MATL BEING
WORKED, PROCESS, PROCS & CONSUMABLES USED. OTHER CNDTNS WHICH
INFLUENCE COMPOSITION & QTY (OTHER INFO)
=================== Toxicological Information===================
Toxicological Information:OTHER INFO: MATLS ARE CONSUMED, FUME & GAS
DECOMP PRODS GENERATED DIFFER IN PERCENT & FORM FROM INGREDS
LISTED. DECOMP PRODS OF NORM OPERATION INCL THOSE ORIGINATING FROM
VOLITALIZATION, RXN OR OXIDAT ION OF INGREDS, PLUS THOSE FROM MATL
BEING WORKED & COATINGS, ETC. NOTED ABOVE. REASONABLY EXPECTED
DECOMP PRODS FROM NORM USE OF PRODS INCL COMPLEX OF OXIDES &
FLUORIDES OF LISTED MATLS AS WELL AS CA RBON MONOXIDE, CARBON
DIOXIDE & NITROGEN OXIDES (REFER TO "CHARACTERIZATION OFARC WELDING
FUME" AVAIL FROM AWS). TLV FOR MANGANESE (0.2 MG/M3) MAY BE REACHED
BEFORE GEN LIM FOR WELDING FUMES OF 5 MG/M 3 IS REACHED. ONLY
(ECOLOGICAL INFO)
===================== Ecological Information =====================
Ecological:TOXICOLOGICAL INFO: WAY TO DETERMINE TRUE IDENTITY OF DECOMP
PRODS IS BY SAMPLING & ANALYSIS. COMPOSITION & QTY OF FUMES & GASES
TO WHICH WORKER MAY BE OVEREXP CAN BE DETERMINED FROM SAMPLE
OBTAINED F ROM INSIDE WELDER'S HELMET, IF WORN, ORIN WOEKER'S BRTHG
ZONE. SEEN ANSI/AWS F1.1 "METHOD FOR SAMPLING AIRBORNE PARTICLES
GENERATED BY WELDING & ALLIED PROCESSES," AVAIL FROM AWS.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSABLE CONTAINER OR
LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER, IN FULL COMPLIANCE
WITH FEDERAL, STATE AN D LOCAL REGULATIONS.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:813 0734 EASTMAN ECP-2B FINAL RINSE WITH DEARCIDE 702
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 95-99%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYOXYETHYLENE (12) TRIDECYL ALCOHOL
CAS:24938-91-8
RTECS #:YD4571000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:MAGNESIUM NITRATE
CAS:10377-60-3
RTECS #:OM3750000
Fraction by Wt: <0.1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG MG/M3 CEILING
ACGIH TLV:10 MG MG/M3
Ingred Name:MAGNESIUM CHLORIDE,
CAS:7786-30-3
RTECS #:OM2800000
Fraction by Wt: < 0.1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:5-CHLORO-2-METHYL-4-ISOTHIOAZOLIN-3-ONE
CAS:26172-55-4
RTECS #:NX8156850
Fraction by Wt: < 0.1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): NOT GIVEN
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. MAY CAUSE TRANSIENT EYE IRRITATION. LOW
SKIN CONTACT HAZARD FOR RECOMMENDED HANDLING. EXPECTED TO BE A LOW
INGESTION HAZARD.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMEEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER IF ALLOWABLE WITH LARGE AMOUNTS
OF WATER. OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT
MATERIAL, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN
SURFACE TO REMOVE RESIDUA L CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION. WASH
THOROUGHLY AFTER HANDLING. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:NOT GIVEN
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID, NO ODOR
Percent Volatiles by Volume:95-99%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE WITH COMMON MATERIALS AND CONTAMINANTS WITH WHICH THE MATERIAL MAY
REASONABLY COME INTO CONTACT.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. MAY REQUIRE NEUTRALIZATION IF PH
< 2.0 OR PH > 12.5. DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE ANDLOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DRI ICE, SOLID CARBON DIOXIDE, CARBON ICE
CAGE:KO836
CAGE:6Z872
CAGE:KO836
============= Composition/Information on Ingredients =============
Ingred Name:CARBON DIOXIDE
*PROPOSED CHANGE FROM 15,000 MOLAR PPM
CAS:124-38-9
RTECS #:FF6430000
Fraction by Wt: 100%
Other REC Limits:*
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM/30000STEL;93
===================== Hazards Identification =====================
LD50 LC50 Mixture:RAT-INHALE LCL0: 657,190 PPM-15 MIN.; *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NERVOUS SYSTEM CONTROL OF RESPIRATION
IS DEPENDENT ON CO2 LEVEL BREATHED IN AIR. BY REDUCING OXYGEN LEVEL
IN AIR, CO2 CAN CAUSE SUFFOCATION. SYMPTOMS OF OVEREXPOSURE INCLUDE
HEADACHE, DIZZINESS, SHORT NESS OF BREATH, MUSCULAR WEAKNESS,
DROWSINESS, RINGING IN EARS. HIGH CONCENTRATIONS PRODUCE A FAINT
ACID TASTE & CAN **
Explanation of Carcinogenicity:*RAT(10 DAYS PREG)-INHALE TLCO: 60,000
PPM-24 HRS TERATOGENIC EFFECTS; HUMAN-INHALE TCLO: 2,000 PPM
PULMONARY EFFECTS.
Effects of Overexposure:**CAUSE PARALYSIS OF BREATHING CONTROL CENTERS
OF NERVOUS SYSTEM. INHALE: LOW CONC (3-5 MOLOR %) CAUSE INCREASED
RESPIRATION & HEADACHE, 8-15 MOLAR % CONC CAUSE HEADACHE, NAUSEA,
VOMITING-LEADS TO UNC ONSCIOUSNESS IF NOT MOVED TO FRESH AIR.MAY
CAUSE COMA & DEATH. CONTINUAL DERMAL CONTACT-FROSTBITE OR CRYOGENIC
"BURNS".
======================= First Aid Measures =======================
First Aid:PROMPT MED AID IS MANDATORY IN ALL CO2 OVEREXPOSURE CASES.
EQUIP RESCUE PERSONNEL W/SCBA. INHALE: IMMED REMOVE TO FRESH AIR.
IF UNCONSCIOUS, GIVE CPR & OXYGEN. ASSURE THAT VOMITED MAT'L DOES
NOT OBSTR UCT AIRWAY BY USE OF POSITIONAL DRAINAGE. FROSTBITE:
FLUSH AFFECTED AREAS W/LUKEWARM WATER. DO NOT USE HOT WATER. IMMED
SEE DR IF CRYOGENIC "BURNS" RESULT IN SKIN BLISTERING OR DEEP
TISSUE FREEZING.
===================== Fire Fighting Measures =====================
Flash Point:NA
Extinguishing Media:NONFLAMMABLE, INERT GAS.
Fire Fighting Procedures:USE WATER SPRAY TO COOL FIRE-EXPOSED
CONTAINERS. MATERIAL IS NONCOMBUSTIBLE & CAN BE USED AS A FIRE
EXTINGUISHING AGENT PRIMARILY FOR ITS SMOTHERING EFFECT.
Unusual Fire/Explosion Hazard:NOT EFFECTIVE ON FIRES INVOLVING
CHEMICALS W/THEIR OWN OXYGEN SUPPLY, FIRES INVOLVING REACTIVE
METALS, OR THEIR HYDRIDES AS THESE MATERIALS CAN DECOMPOSE CO2.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA OF MAJOR SPILL OR RELEASE OF
CO2. NOTIFY SAFETY PERSONNEL. PROVIDE VENTILATION. CLEAN-UP
PERSONNEL NEED SPECIAL TRAINING AND PROTECTION AGAINST CONTACT WITH
VERY COLD MATERIALS OR EXCESS IVE INHALATION OF GASEOUS CO2.
======================Handling and Storage ======================
Handling and Storage Precautions:DRY CO2 CAN BE HANDLED WITH MOST
COMMON STRUCTURAL MATERIALS. AT NORMAL TEMPERATURES, CO2 IS
COMPATIBLE WITH MOST PLASTICS AND ELASTOMERS.
Other Precautions:MOIST CO2 IS CORROSIVE BY ITS FORMATION OF CARBONIC
ACID. FOR THESE APPLICATIONS, 316, 309 & 310 STAINLESS STEELS MAY
BE USED AS WELL AS HASTELLOY A, B & C & MONEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:POSITIVE PRESSURE AIR LINE W/MASK OR SCBA FOR
EMERGENCY USE. PROVIDE APPROVED SUPPLIED-AIR OR SELF-CONTAINED
RESPIRATOR FOR USE IN NON-ROUTINE OR EMERGENCY SITUATIONS
W/EXPOSURE ABOVE TLV. FULL FACEPI ECE REQUIRED FOR CONCENTRATIONS
>10%.
Ventilation:LOCAL EXHAUST: TO PREVENT ACCUMULATION ABOVE THE TWA.
Other Protective Equipment:SAFETY SHOES, SOLID CO2 HANDLING "TONGS".
FACESHIELD, ETC.).
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:G3
Boiling Pt:B.P. Text:-109F,-79C
Melt/Freeze Pt:M.P/F.P Text:-70F,-57C
Vapor Pres:@70F=844.7
Vapor Density:.1144LB/FT
Spec Gravity:95.64 LB/FT3
Solubility in Water:COEFFICIENT = .8704
Appearance and Odor:WHITE OPAQUE SOLID; COLORLESS, ODORLESS GAS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SODIUM PEROXIDE W/AL OR MG. REACTIVE METALS, THEIR HYDRIDES & MAT'LS
LIKE DIETHYL MAGNESIUM, MOIST CESIUM OXIDE, ETC.
Hazardous Decomposition Products:CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:ALLOW GAS TO BLEED OFF AT A MODERATE RATE OR
SOLID TO SUBLIME TO A WELL VENTILATED AREA. DO NOT PUT DRY ICE IN A
CLOSED CONTAINER WHERE EVOLVED GAS CANNOT ESCAPE. REMOVE SCRAP
SOLID TO HOOD W/FORCED V ENT OR TO A REMOTE OUTSIDE AREA.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:D-70 DEVELOPER (NSN CANCELLED-SEE SUPPL)
CAGE:98733
CAGE:98733
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:TALC (CONTAINING NO ASBESTOS)
CAS:14807-96-6
RTECS #:WW2710000
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST; 9192
Ingred Name:ALUMINA AS FILLER
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SLIGHT SKIN IRRITATION;
VAPORS OR OIL MIST MAY CAUSE MILD IRRITATION OF UPPER RESPIRATORY
TRACT.
Effects of Overexposure:EYES:MAY CAUSE IRRITATION; SKIN:SLIGHT
IRRITATION ON CONTACT WITH LIQUID;INHALATION:VAPORS OR MIST OF
PRODUCT MAY CAUSE MILD IRRITATION OF UPPER RESPIRATORY TRACT. EARLY
TO MODERATE CNS DEPRESSION MAY BE EVIDENCED BY
GIDDINESS,HEADACHE,DIZZINESS,NAUSEA. INGESTION: MAY RESULT IN
VOMITING.ASPIRATION MUST BE AVOIDED.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN AND RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH WATER FOR AT LEAST 15 MINUTES.GET MEDICAL
HELP IF IRRITATION OCCURS OR PERSISTS; SKIN:FLUSH WITH WATER.WASH
WITH LUKE WARM WATER & SOAP.GET MEDICAL HELP FOR PERSISTING
IRRITATION; INHA LATION:REMOVE TO FRESH AIR.PROVIDE OXYGEN IF
BREATHINGIS DIFFICULT.GET MEDICAL ASSISTANCE IF NEEDED; INGESTION:
IF SWALLOWED, INDUCE VOMITING IF VICTIM IS CONSCIOUS. GET MEDICAL
ASSISTANCE.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:53F/11.7C
Lower Limits:2.0
Upper Limits:12.0
Extinguishing Media:WATER FOG, "ALCOHOL" FOAM, DRY CHEMICAL, CARBON
DIOXIDE. DO NOT USE DIRECT STREAM OF WATER ON THE FIRE.
Fire Fighting Procedures:IN CONFINED AREA,DO NOT ENTER WITHOUT A FULL
BUNKER GEAR INCLUDING A POSITIVE PRESSURE NIOSH APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CONTAINERS MAY BURST AND/OR RUPTURE IN
INTENSE HEAT OF FIRE. PER MANUFACTURER, PREHEATED PRODUCT MAY
IGNITE IN AIR WHEN EXPOSED TO FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIM ALL IGNITION SOURCES.WEAR APPROPRIATE
PROTECTIVE CLOTHING AND RESPIRATORS.HANDLING EQUIPMENT MUST BE
GROUNDED.SM LIQ:SOAK UP WITH ABSORBENT CLAY,SAND,ETC; KEEP WASTE IN
SEALED,NON-LEAKING CONTAIN ERS.LG LIQ:DIKE LIQUID & PUMP INTO
SALVAGE TANK.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM SOURCES OF
HEAT/IGNITION.STORE IN COOL,DRY & VENTILATED AREA.DO NOT STORE OR
HANDLE IN ALUMINUM EQUIPMENT;AVOID PHYSICAL DAMAGE TO CONT
Other Precautions:MINIMIZE SKIN CONTACT.AVOID BREATHING VAPORS. DO NOT
STORE OR HANDLE IN ALUMINUM EQUIPMENT AT TEMPERATURES ABOVE 120F.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NEEDED IN NORMAL CONDITIONS OR USES WHEN
VAPORS/MIST CONCENTRATIONS ARE BELOW TLV/PEL LIMITS. WEAR NIOSH
APPROVED RESPIRATOR IF EXPOSURE EXCEEDS TLV LIMITS.
Ventilation:LOCAL EXHAUST OR MECHANICAL(GENERAL) TO MAINTAIN TLV OR
BELOW TLV LIMITS.PER MFR,PROVIDE EXPLOSION PROOF VENTILATION.
Other Protective Equipment:CHEMICAL RESISTANT APRON TO PREVENT
CLOTHING/SKIN CONTACT.
Work Hygienic Practices:WASH HANDS WITH SOAP & WATER BEFORE EATING,
SMOKING OR USING TOILET FACILITIES;DO NOT EAT/DRINK IN VAPOR
CONTMNTD AREA.
Supplemental Safety and Health
UNDER QPL-25135-13,D-70 DEVELOPER WAS CLASSIFIED AS PRODUCT FOR GROUPS
I THROUGH VII OF MIL-I-25135C; THE NSN WAS FOR GROUP VI DEVELOPERS.
THE NSN HAS BEEN CANCELLED AS DUPLICAT OF 6850-01-264-8679.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:=82.2C, 180.F
Vapor Pres:33 @ 68F
Vapor Density:2.1
Spec Gravity:ABOUT 0.8
Evaporation Rate & Reference:1.4 (ETHYL ACETATE = 1)
Solubility in Water:PARTIAL
Appearance and Odor:WHITE ,MILKY SUSPENSION, MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL
Stability Condition to Avoid:SOURCE OF HEAT/IGNITION. AVOID EXPOSURE TO
OXIDIZING MATERIALS.
Hazardous Decomposition Products:CAN FORM OXIDES OF CARBON (CARBON
MONOXIDE,CARBON DIOXIDE) AND OTHER UNIDENTFIED ORGANIC COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:PER MANUFACTURER, PLACE WASTE LIQ IN NON-LEAKING
CONTAINERS,SEAL AND DISPOSE OF AS EPA HAZARDOUS WASTE #
D001,IGNITABLE WASTE, IN FULL COMPLIANCE WITH ALL FEDERAL,LATEST
EPA, STATE & LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:F 401 READY KILL W/DURSBAN
CAGE:53798
CAGE:53798
============= Composition/Information on Ingredients =============
Ingred Name:RESMETHRIN, (5-BENZYL-3-FURYL)
METHYL-2,2-DIMETHYL-3-(2-METHYLPROPENYL)-CYCLOPROPANE CARBOXYLATE
CAS:10453-86-8
RTECS #:GZ1310000
Fraction by Wt: 0.1%
Ingred Name:CHLORPYRIFOS (O,O,-DIETHYL-O-,3,5,6-TRICHLORO-2-PYRIDYL
PHOSPHOROTHIOATE)
CAS:2921-88-2
RTECS #:TF6300000
Fraction by Wt: 0.5%
OSHA PEL:0.2 MG/CUM (SKIN)
ACGIH TLV:0.2 MG/CUM (SKIN)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: HARMFUL IF SWALLOWED.
EYES/SKIN: IRRITATION. CHLORPYRIFOS CAUSES CHOLINERGIC EFFECTS &
MAY BE ABSORBED THROUGH THE SKIN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, CHOLINERGIC EFFECTS: PUPIL
CONTRACTION, MUSCLE TWITCHING, NAUSEA & VOMITING.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH IMMEDIATELY
W/PLENTY OF COOL WATER FOR 15 MINS. SKIN: WASH WELL W/SOAP & WATER.
OBTAIN MEDICAL ATTENTION IN ALL CASES. NOTE TO PHYSICIAN:
CHLORPYRIFOS IS A CHOLINESTERASE INHABITER. IF SYMPTOMS OF
CHOLINESTERASE INHABITER APPEAR, ATROPINE ONLY BY INJECTION IS AN
ANTIDOTE.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. SOAK UP EXCESS W/ABSORBENT &
DISCARD IN PROPER RECEPTACLE. REPORT ANY SPILLS OVER 20 GALLONS TO
THE APPROPRIATE EMERGENCY RESPONSE AGENCIES.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE BELOW FREEZING. DON'T
REUSE EMPTY CONTAINERS. DON'T STORE NEAR FOOD/FEED. DON'T CUT EMPTY
DRUMS W/TORCH/WELDING EQUIPMENT.
Other Precautions:DON'T APPLY PRODUCT IN CONDUITS/MOTOR
HOUSING/JUNCTION & SWITCH BOXES OF OTHER ELECTRICAL EQUIPMENT
BECAUSE OF POSSIBLE SHOCK HAZARD. AVOID CONTACT W/EYES,
SKIN/CLOTHING. DON'T CONTAMINATE FOOD/FEEDST UFFS/WATER SUPPLIES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV IS EXCEEDED, WEAR APPROVED PESTICIDE
RESPIRATOR.
Ventilation:USE PRODUCT W/ADEQUATE VENTILATION.
Other Protective Equipment:CLEAN WATER SOURCE
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING/BEFORE
EATING/SMOKING.
Supplemental Safety and Health
THOROUGHLY WASH FOOD CONTACT SURFACES W/SOAP. DON'T ALLOW CHILDREN/PETS
TO CONTACT SURFACES UNTIL SPRAYS HAVE DRIED. REMOVE PETS/COVER FISH
TANKS BEFORE SPRAYING. DON'T APPLY DIRECTLY TO WATER. DON'T
CONTAMINATE WATER BY CLEANING. READ & FOLLOW LABEL DIRECTIONS
BEFORE USING. NOT FOR HOUSEHOLD USE/RESALE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:200-250F
Spec Gravity:0.99
Solubility in Water:COMPLETE
Appearance and Odor:A PALE YELLOW EMULSION W/MILD ODOR.
Percent Volatiles by Volume:95/WT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, BASES/ALKALINE MATERIAL. DON'T MIX W/OTHER
CHEMICALS.
Stability Condition to Avoid:EXCESSIVE HEAT & OTHER IGNITION SOURCES.
Hazardous Decomposition Products:CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. NOTE: REPORTABLE QUANTITY OF CHLOROPYRIFOS IS 1 LB. 24
GALLONS OF READY KILL W/DURSBAN CONTAINS 1 LB OF CHLORPYRIFOS.
FOLLOW LABEL DISPOSAL INSTRUCTI ONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:300-42 CRIMSON SUNSET, CARRIAGE HOUSE (SUP DAT)
CAGE:EO376
CAGE:EO376
CAGE:85520
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 20-35%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:NAPHTHA, LIGHT AROMATIC (SOLVENT NAPHTHA); (HYDROCARBON
SOLVENT)
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 0-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC; (HYDROCARBON
SOLVENT)
CAS:64742-88-7
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:100 MG/M3 (MFR)
Ingred Name:MIXTURE; (FOLPET)
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PIGMENTS
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUND: 2.53 TO 2.87
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SPILL PROC: AND POLLUTION CONTROL AGENCIES. CALL SPILL
RESPONSE TEAMS IF SPILL IS LARGE.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: USE ONLY WITH ADEQUATE VENTILATION. AVOID
PROLONGED OR REPEATED BREATHING OF VAPORS.
RTECS #:9999999ZZ
Ingred Name:RESP PROT: PARTICULATE & GAS & VAP. IN CONFINED AREAS, USE
NIOSH APPRVD AIR LINE TYPE RESPS/HOODS. RESP PROT MAY(ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: ALSO BE NEC IN ANY LATER MANUFACTURING OPERATIONS IN
WHICH THESE PRODS MAY BECOME AIRBORNE IN FORM OF VAP/DUST.
RTECS #:9999999ZZ
Ingred Name:VENT: MOST HAZ ING BELOW ACCEPTABLE LIM, LEL BELOW STATED
LIM & TO REMOVE DECOMP PRODS DURING WELDING/FLAME (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: CUTTING ON SURFACES COATED WITH THESE PRODUCTS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY CAUSE NOSE, THROAT & EYE
IRRIT. CHRONIC: RPTS HAVE ASSOC RPTD & PRLNG OCCUP OVEREXP TO SOLVS
W/PERM BRAIN & NERV SYS DMG. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING & INHALING CONTENT S MAY BE HARMFUL/FATAL.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SYMPTOMS OF OVEREXPOSURE INCLUDE DIZZINESS,
HEADACHE, INTOXICATION WITH EUPHORIA LEADING TO UNCONSCIOUSNESS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LUKE WARM WATER FOR AT LEAST 15 MIN. SEEK MD
IMMED. SKIN: FLUSH WASH W/COPIOUS AMTS OF LUKE WARM WATER. REMOVE
CONTAM CLTHG PROMPTLY. IF IRRIT OCCURS, GET MED ATTN. INHAL: REMOVE
TO FRES H AIR. RESTORE BRTHG IF REQUIRED. CONT MD IMMED. INGEST:
RINSE MOUTH IMMED. GIVE 6-8 OZ OF LIQ (NEVER GIVE ANYTHING BY MOUTH
TO AN UNCON PERS). DO NOT INDUCE VOMIT UNLESS ADVISED BY MD. CONT
MD IMMED.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:104F,40C
Lower Limits:0.5%
Upper Limits:7.0%
Extinguishing Media:NFPA CLASS B EXTINGUISHER IS DESIGNED TO EXTINGUISH
NFPA CLASS IB FLAMMABLE LIQUID FIRES.
Fire Fighting Procedures:WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER SPRAY MAY BE INEFFECTIVE. WATER MAY BE USED TO COOL CLSD
CONTRS TO PVNT PRESS BUILD-UP & POSS (SUP DAT)
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPKS & OPEN FLAME. CLSD CONTRS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. DO NOT APPLY TO HOT (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:STOP &/CONTAIN DISCHARGE IF IT MAY BE DONE
SAFELY. KEEP ALL SOURCES OF IGNIT AWAY. VENT AREA OF SPILL. USE
NON-SPK TOOLS FOR CLEANUP. COVER W/INERT MATL TO REDUCE FUMES. KEEP
OUT OF DRAINS, SEWERS/WAT ERWAYS. CONT FIRE AUTH. NOTIFY LOC
HLTH(ING 7)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT BREATHE VAPS/SPRAY MIST. DO NOT
STORE >120F, OR TAKE INTERNALLY. GROUND CONTRS WHEN POURING & LIM
FREE-FALL TO FEW INCHES TO PVNT STATIC SPKS.
Other Precautions:AVOID SPONT COMBUST OF CONTAM RAGS/OTHER EASILY IGNIT
ORG MATLS BY IMMED IMMERSION IN WATER. EMPTIED CONTRS MAY CONTAIN
HAZ PROPERTIES. DO NOT CUT/PUNCTURE CONTR. DO NOT WELD NEAR CONTR.
KEEP CONTR TI GHTLY CLSD WHEN NOT IN USE. (ING 8)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN OUTDOOR/OPEN AREAS, USE NIOSH APPRVD MECH
FILTER RESP TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY DURING
SPRAY APPLICATION. IN RESTRICTED VENT AREAS, USE NIOSH APPRVD
CHEM-MECH FILTERS DESIGNEDTO REMOVE A COMBINATION OF (ING 9)
Ventilation:USE VENT AS REQUIRED TO CTL VAP CONCS. PROVIDE GEN
DILUTION/LOC EXHST VENT IN VOL & PATTERN TO KEEP TLV OF THE (ING
11)
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
APRON SHOULD BE WORN TO AVOID SKIN CONT.
Work Hygienic Practices:WASH HANDS THORO BEFORE EATING & USING
WASHROOM. REMOVE CONTAM CLTHG IMMED & PROPERLY LAUNDER BEFORE
REUSE.
Supplemental Safety and Health
TRADE NAME/PART #: EXTERIOR ALKYD GLOSS HOUSE & TRIM PAINT. % VOLAT:
39.25-44.26. FIRE FIGHT PROC: AUTOIGNIT/EXPLO WHEN EXPOSED TO
EXTREME HEAT. IF WATER IS USED, FOG NOZZ ARE PREF. EXPLO HAZ: SURF.
N EVER USE WELDING/CUTTING TORCH ON/NEAR CONTR (EVEN EMPTY) BECAUSE
PROD (EVEN RESIDUE) MAY IGNITE EXPLOSIVELY.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:3.0
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
THESE PRODUCTS ARE INCOMPATIBLE WITH STRONG ACIDS.
Stability Condition to Avoid:AVOID EXPOSURE TO SPARKS, OPEN FLAME, HOT
SURFACES AND ALL SOURCES OF HEAT AND IGNITION.
Hazardous Decomposition Products:MAY PRDCE HAZ FUMES WHEN HEATED TO
DECOMP AS IN WELDING. FUMES MAY CONTAIN CARBON MONOXIDE/DIOXIDE &
OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT FLUSH TO SEWER, WATERSHED OR WATERWAY.
DISPOSE OF THESE PRODUCTS IN ACCORDANCE WITH APPLICABLE LOCAL,
COUNTY, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HYDROGEN PEROXIDE SOLUTION 30%, 2186
CAGE:IO255
CAGE:70829
CAGE:IO255
============= Composition/Information on Ingredients =============
Ingred Name:HYDROGEN PEROXIDE (SARA 302)
CAS:7722-84-1
RTECS #:MX0900000
Fraction by Wt: 29-32%
OSHA PEL:1 PPM
ACGIH TLV:1 PPM; 9495
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 68-71%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MATLS TO AVOID: STANDING IN CONTACT WITH READILY FLAMMABLE
MATERIALS.
RTECS #:9999999ZZ
Ingred Name:CNDTNS (STAB): DECOMPOSES TO RELS OXYGEN. UNSTABLE W/HEAT
MAY RSLT IN DANGEROUS PRESS. A STRONG OXIDIZER, (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: REACTS VIOLENTLY UPON CNTCT W/MANY ORG SUBSTANCES
PARTICULARLY TEXTILE & PAPER. AVOID LIGHT & KEEP IN A (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: CLOSED BUT VENTED CONTAINER TO PREVENT EVAPORATION
(CONCENTRATION) AND CONTAMINATION.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP: SPLASHES CAN CAUSE PERMANENT TISSUE
DESTRUCTION. CHRONIC: NO INFORMATION FOUND.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: SHOES BEFORE REUSE. IF ALLOWED TO DRY ON
CLTHG EVAP LEADS TO CONC & INCREASED POSSIBILITY OF (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: IGNIT. EYE: IMMED FLUSH W/PLENTY OF H*2O FOR AT
LEAST 15 MIN LIFTING LOWER & UPPER EYELIDS OCCASIONALLY. (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: GET MED ATTN IMMED. NOTE TO MD: PULM EDEMA MAY BE
DELAYED FOR 24 TO 72 HRS. KEEP UNDER OBSERVATION (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: GASTRIC LAVAGE MAY BE NECESSARY IF SWALLOWED.
ANALYSIS OF BODY FLUID (PARTICULARLY GASTRIC ASPIRATES) (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: USING THE TITANIUM CHLORIDE REACTION IF DONE
IMMEDIATELY WILL REVEAL PEROXIDES.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: & HOLD IN A POND/DYKED AREA UNTIL PEROXIDE
DECOMP FOLLOWED BY DISCHARGE INTO A SUITABLE TREATMENT (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: SYS. MAY BE NEUTRALIZE W/SODIUM
METABISULFITE/SODIUM SULFITE AFTER DILUTING TO 5-10% PEROXIDE. DO
NOT (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: FLUSH UNDILUTED MATERIAL TO SEWER. THIS OXIDIZING
MATERIAL CAN INCREASE THE FLAMMABILITY OF ADJACENT (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: COMBUSTIBLE MATERIALS. EMPTY CONTAINERS SHOULD BE
RINSED WITH WATER BEFORE DISCARDING.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH: DISP REGS. DILUTE W/H*2O & FLUSH TO SEWER
IF LOC ORDINANCES ALLOW, OTHERWISE, WHATEVER CANNOT (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17: BE SAVED FOR RECOVERY/RECYCLING SHOULD BE MANAGED
IN AN APPROP & APPRVD WASTE DISP FACILITY. PROCESSING,(ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: USE/CONTAM OF THIS PROD MAY CHANGE WASTE MANAGEMENT
OPTIONS. STATE & LOCAL DISP REGS MAY DIFFER FROM (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19: FED DISP REGS. DISPOSE OF CONTAINER & UNUSED
CONTENTS IN ACCORDANCE WITH FEDERAL, STATE & LOCAL REQUIREMENTS.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: CONTAM FROM ANY SOURCE (DUST, METALS) MAY CAUSE
RAPID DECOMP W/GENERATION OF LRG QTIES OF OXYGEN (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21: GAS & HIGH PRESS. RINSE EMPTY CNTNRS THOROUGHLY
W/CLEAN WATER. GLASS, POLYETHYLENE, STAINLESS STEEL (ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22: & ALUMINUM ARE REC MATS FOR STORAGE CNTNRS. CNTNRS
OF THIS MATL MAY BE HAZ WHEN EMPTY SINCE THEY RETAIN (ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23: PRODUCT RESIDUES (VAPORS LIQUID); OBSERVE ALL
WARNINGS AND PRECAUTIONS LISTED FOR THE PRODUCT.
RTECS #:9999999ZZ
Ingred Name:EYE PROT: AND FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: VAPS ARE CORR & IRRIT TO RESP
TRACT. INHAL OF MIST MAY BURN MUC MEMB OF NOSE & THROAT. IN SEV
CASES EXPOS MAY RSLT IN PULM EDEMA & DEATH. INGEST: CORR & IRRIT TO
MOUTH, THROAT, & ABDOMEN. LRG D OSES MAY CAUSE SYMPS OF ABDOM PAIN,
VOMIT, & DIARR AS WELL AS BLISTERING/TISS DESTRUCTION. STOMACH
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: DISTENTION (DUE TO RAPID LIBERATION
OF OXYGEN), & RISK OF STOMACH PERFORATION, CONVL, PULM EDEMA, COMA,
POSS CEREBRAL EDEMA (FLUID ON BRAIN), & DEATH ARE POSS. SKIN: CORR
SYMPS OF REDNESS, P AIN, & SEV BURN CAN OCCUR. EYE: VAPS AREVERY
CORR & IRRIT TO EYES. SYMPS INCL PAIN, REDNESS & BLURRED VISION.
(ING 7)
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS OR EYE PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION MAY BE
MORE SUSCEPTIBLE TO THE EFFECTS OF THE SUBSTANCE.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTF RESP. IF
BRTHG IS DFCLT GIVE OXYGEN. GET MED ATTN IMMED. INGEST: DO NOT
INDUCE VOMIT. GIVE LRG QTIES OF H*2O. NEVER GIVE ANYTHING BY MOUTH
TO AN UNC ONS PERS. GET MED ATTN IMMED. SKIN: IMMED FLUSH W/PLENTY
OF H*2O FOR AT LEAST 15 MIN WHILE REMOVING CONTAMD CLTHG & SHOES.
GET MED ATTN IMMED. WASH CLTHG BEFORE REUSE. THOROUGHLY CLEAN (ING
8)
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY MAY BE USED TO EXTING SURROUND FIRE &
COOL EXPOS CNTNRS. WATER SPRAY WILL ALSO REDUCE FUMES & (SUPDAT)
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:FIRE: NOT COMBUST BUT SUBSTANCE IS A
STRONG OXIDIZER & ITS HEAT/RXN W/REDUCING AGENTS/COMBUST MAY CAUSE
IGNIT. INCREASES FLAMM OF COMBUST ORG & (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:CAUTION! CAUSTIC MATL. CAUSES FIRES W/ORG
MATL. VENT AREA OF LEAK/SPILL. WEAR APPROP PERS PROT EQUIP AS
SPECIFIED IN SECTION 8. CNTN & RECOVER LIQ WHEN POSS. DO NOT RETURN
SPILL MATL TO ORGINAL CNTNR. LRGR SPILLS: DILUTE W/LRG AMT OF H*2O
(ING 13)
Neutralizing Agent:SODIUM METABISULFITE OR SODIUM SULFITE AFTER
DILUTING TO 5-10% PEROXIDE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL (<35C) WELL-VENTILATED
DARK AREA SEPARATED FROM COMBUSTIBLE SUBSTANCES, REDUCING AGENTS,
STRONG BASES, ORGANICS.
Other Precautions:DO NOT STORE ON WOODEN SHELVES/FLOORS. SUGGEST
ROTATION OF STOCK. CNTNRS MUST BE VENTED, BUT CHECK PERIODICALLY
FOR BULGING CNTNRS WHICH CAN BURST FROM PRESS. PROTECT CNTNRS FROM
PHYSICAL DMG, CONTAM, HEAT & INCOMPATIBLES. (ING 21)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF THE EXPOSURE LIMIT IS EXCEEDED, WEAR A NIOSH
APPROVED SUPPLIED AIR, FULL-FACEPIECE RESPIRATOR, AIRLINED HOOD, OR
FULL-FACEPIECE SELF-CONTAINED BREATHING APPARATUS. THIS SUBSTANCE
HAS UNKNOWN WARNIN G PROPERTIES.
Ventilation:SYS OF LOC &/GEN EXHST IS REC TO KEEP EMPLOYEE EXPOS BELOW
AIRBORNE EXPOS LIMS. FOR MORE SPECIFIC INFO CNTCT NEHC
Other Protective Equipment:ANSI APPRVD EMER EYE WASH & DELUGE SHOWER .
FOR MORE SPECIFIC INFORMATION CONTACT NEHC .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
VP: 25 @ 30C (86F). EXTING MEDIA: IRRITANT GASES. EXPLO HAZ: READILY
OXIDIZABLE MATLS. EXPLOSION: CNTCT W/OXIDIZABLE SUBSTANCES MAY
CAUSE EXTREMELY VIOLENT COMBUST. DRYING OF CONCENTRATED HYDROGEN
PER OXIDE ON CLTHG/OTHER COMBUST MATLS MAY CAUSE FIRE/EXPLOSION.
SEALED CNTNRS MAY RUPTURE WHEN HEATED.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:226F,108C
Melt/Freeze Pt:M.P/F.P Text:32.5F,0.3C
Vapor Pres:SUPDAT
Vapor Density:1.11
pH:3.3
Evaporation Rate & Reference:<1 (BUAC = 1)
Solubility in Water:INFINITELY SOLUBLE
Appearance and Odor:CLEAR COLORLESS LIQUID; SLIGHT ACRID ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HEAT, REDUCING AGENTS, ORG MATLS, DIRT, ALKALIS, RUST, & MANY METALS.
SPONTANEOUS COMBUSTION MAY OCCUR ON (ING 3)
Stability Condition to Avoid:AVOID EXCESS HEAT & CNTCT W/COMBUST/ORG
MATLS. LIGHT & INCOMPATIBLES. NORMALLY STABLE IF UNCONTAMD, BUT
SLOWLY (ING 4)
Hazardous Decomposition Products:DECOMPOSES TO WATER & OXYGEN W/RAPID
HEAT RELEASE. USE VENTED CNTNRS. THE SOLUTION CAN DECOMPOSE
VIOLENTLY UPON HEATING.
==================== Disposal Considerations ====================
Waste Disposal Methods:WHATEVER CANNOT BE SAVED FOR RECOVERY/RECYCLING
SHOULD BE HNDLD AS HAZ WASTE & SENT TO A RCRA APPRVD WASTE
FACILITY. PROCESSING USE/CONTAM OF THIS PROD MAY CHANGE WASTE
MANAGEMENT OPTIONS. STATE & LOC AL DISPOSAL REGS MAY DIFFER FROM
FED (ING 17)
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ALUMINUM ANTI-SEIZE TM2524. 76306
CAGE:GO998
CAGE:45092
CAGE:GO998
============= Composition/Information on Ingredients =============
Ingred Name:ETHANE, 1,1,1-TRICHLORO-; (1,1,1-TRICHLOROETHANE)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 50%
OSHA PEL:350 PPM;450 STEL
ACGIH TLV:350 PPM;450 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: <23%
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:PROPANE, 2-METHYL-; (ISOBUTANE)
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: <23%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BUTANE; (N-BUTANE)
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: <23%
OSHA PEL:800 PPM
ACGIH TLV:800 PPM
Ingred Name:GRAPHITE
CAS:7782-42-5
RTECS #:MD9659600
Fraction by Wt: 1%
OSHA PEL:15 MPPCF RDUST
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:ALUMINUM
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 3%
OSHA PEL:15MG/M3 DUST;5 FUME
ACGIH TLV:10MG/M3 DUST
Ingred Name:SILICA
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLYBUTENE POLYMER
Fraction by Wt: 22%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC: MAY CAUSE DIZZ/NARCOS
IN HIGH VAP CONC. WILL CAUSE DEFAT OF SKIN. EFTS ARE REVRSIBLE.
LONG TERM EXPOS (YEARS) TO HIGH CONC OF VAP MAY CAUSE LUNG,
LIVER/KIDNEY DAM. SOLVENTS LISTED HAVE BEEN REPORTED TO AFFECT
CNS. EYE & SKINIRRITANT; ASPIR HAZ IF SWALLOWED. INHAL: DFCLTY IN
BRTHG. SKIN:(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: REDNESS. INGEST: VOMITING.
CHLOROCARBON MATLS HAVE PRDCD SENSITIZATION OF MYOCARDIUM TO
EPINEPHRINE IN LAB ANIMALS & COULD HAVE SIMILAR EFFECT IN HUMANS.
ADRENOMIMETICS (E.G., EPINEPHRINE) M AY BE CONTRAINDICATED EXCEPT
FOR LIFE-SUSTAINING USES IN HUMANS ACUTELY OR CHRONICALLY EXPOSED
TO CHLOROCARBONS .
Medical Cond Aggravated by Exposure:HEART DISEASE; RESPIRATORY
DISORDERS.
======================= First Aid Measures =======================
First Aid:INHAL: GIVE OXYGEN. INGEST: DO NOT INDUCE VOMIT. GASTRIC
LAVAGE. EYES: WASH WITH WATER FOR AT LEAST 15 MINUTES. SKIN: WASH
WITH WATER. NEVER ADMINISTER ADRENALIN FOLLOWING OVEREXPOSURE.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-40F,-40C
Lower Limits:1.8%
Upper Limits:12%
Extinguishing Media:TREAT AS PETROLEUM FIRE. CONTAINS POWDERED
ALUMINUM. CO*2, DRY CHEMICAL, NEVER USE WATER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESURE DEMAND SCBA
AND FULL PROTECTIVE EQUIPMENT . AEROSOL CANS MAY RUPTURE WHEN
HEATED.
Unusual Fire/Explosion Hazard:HEATED CANS MAY BURST. THERMAL
DECOMPOSITION PRODUCTS MAY INCLUDE HCL AND PHOSGENE .
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT SWEEPING COMPOUND TO SOAK UP
MATERIAL. PUT INTO CONTAINER. DISPOSE AS HAZARDOUS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS/OPEN
FLAME. STORE AT TEMPERATURES BELOW 120F.
Other Precautions:WHEN SPRAYING MORE THAN 1/2 CAN CONTINUOUSLY OR MORE
THAN 1 CAN CONSECUTIVELY, USE NIOSH/MSHA APPRVD RESP. NO SMOKING IN
AREA OF USE. DO NOT USE IN GEN VICIN OF ARC WELD, OPEN FLAMES/HOT
SURF. HEAT &/ OR UV RADIA MAY CAUSE FORM OF (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED SCBA IF ABOVE TLV LIMIT
EXCEEDING.
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:LONG SLEEVE AND LONG PANTS.
Work Hygienic Practices:DO NOT SMOKE WHILE USING. WASH HANDS AFTER USE.
Supplemental Safety and Health
OTHER PREC: HCL AND/OR PHOSGENE .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:-40F,-40C
Vapor Pres:55PSIG
Vapor Density:4
Spec Gravity:1.1(H*2O=1)
Evaporation Rate & Reference:<1(BUTYL ACETATE=1)
Solubility in Water:NIL
Appearance and Odor:GRAY/SOLVENT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE WITH STRONG OXIDIZERS, ACTIVE METALS.
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:IN FIRE WILL DECOMPOSE TO WATER,
CARBON DIOXIDE, HALOGEN ACIDS, PHOSGENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE AS HAZARDOUS WASTE I/A/W EPA RCRA.
DISPOSE OF I/A/W FEDERAL, STATE AND LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:1008292,LIQUITEX ACRYLIC ARTIST COLOR 8 OZ(
CAGE:BINNE
CAGE:BINNE
CAGE:85419
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHOL CRIMSON
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:INERT, NUISANCE PARTICULATE DUST.
SKIN: NON-TOXIC. INHAL: INERT, NUISANCE PARTICULATE DUST.
INGEST:THIS PROD MAY BE IRRIT TO GI TRACT IF INGESTED. PRODUCT HAS
BEEN CERTIFIED AS NON-TOXIC BY THE AR T & CRAFT MATLS INSTITUTE &
CONFORM TO ASTM D 4236 STD PRACT FOR LABELING ART MATLS FOR CHRONIC
ADVERSE HEALTH HAZARD.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NO SPECIFIC HAZARD IS KNOWN.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN, EYE AND
RESPIRATORY DISORDERS, IMPAIRED FUNCTIONS FROM PRE-EXISTING
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYE: IMMED FLUSH W/WATER FOR AT LEAST 15 MIN. SEEK MEDICAL
ATTENTION IF ANY SYMPTOMS PERSIST. SKIN: WIPE EXCESS FROM SKIN AND
FLUSH WITH WATER USING SOAP IF AVAIL. SEEK MEDICAL ATTENTION IF
IRRITATIONOCCURS. INHAL: REMOVE TO FRESH AIR & TREAT
SYMPTOMATICALLY. INGEST: CONSULT MD, HOSPITAL, POISON CONTROL
CENTER.
===================== Fire Fighting Measures =====================
Flash Point:>212F,>100C
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEMICAL OR CARBON
DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:PRODUCT AS SUPPLIED WILL SPLATTER AND
BOIL ABOVE 212F. PRODUCT WHEN DRY MAY DECOMPOSE AND IGNITE ABOVE
400F.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP RESIDUE W/ABSORB SUCH AS CLAY/SAND/
OTHER SUITABLE MATL; PLACE IN NON-LEAKING CNTNRS FOR PROPER DISP.
FLUSH AREA W/H2O TO REMOVE TRACE RESIDUE;DISP AS NOTED. SML
SPILL:TAKE UP W/ ABSORB MATL & NON-LEAKING CNTNRS; SEAL TIGHTLY
FOR PROPER DISP
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:DO NOT INHALE SPRAY FROM AIR BRUSH. AVOID CONTACT
WITH EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AIR BRUSHING-USE NIOSH/MSHA CERTIFIED
RESPIRATOR. SANDING DRIED PAINT- USE NIOSH/MSHA CERTIFIED
RESPIRATOR. DUST & MIST- NIOSH/MSHA CERTIFIED MASK.
Ventilation:USE VENT AS REQUIRED TO CONTROL VAP CONC. USE WINDOW
EXHAUST FAN TO REMOVE VAPORS AND ASSURE ADEQUATE CROSS VENTILATION.
Other Protective Equipment:EYE WASH FOUNTAINS AND SAFETY SHOWERS SHOULD
BE AVAILABLE FOR USE IN AN EMERGENCY.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR TRADE NAME/PART NO: JAR NAPHTHOL CRIMSON. SPEC GRAV: 1.08-1.44
(H2O=1). % VOLAT: 50+/-10%.
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Density:> 1
Spec Gravity:SUPP DATA
Evaporation Rate & Reference:< 1 (ETHER=1)
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE KNOWN
Hazardous Decomposition Products:CO2, CO AND UNIDENTIFIED (UNKNOWN)
ORGANIC COMPOUNDS MAY BE FORMED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS . REFER TO LATEST EPA/STATE REGS
REGARDING PROPER DISPOSAL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:UNIVERSAL GLOSS MODIFIER, D64 F 100
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:ING 13:SECTION, THE APPLIC LIMITS FOR NUISANCE DUSTS ARE
ACGIH TLV 10 MG/M3 (TOTAL DUST), OSHA PEL 15 MG/M3 (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:(TOTAL DUST), 5 MG/M3 (RESPIRABLE FRACTION).
RTECS #:9999999ZZ
Ingred Name:RESP PROT:APPRVD DUST/MIST RESPIRATOR FOR DUST WHICH MAY BE
GENERATED FROM THIS PROD, UNDERLYING PAINT OR THE ABRASIVE.
RTECS #:9999999ZZ
Ingred Name:VENT:LIMITS. REFER TO OSHA STANDARDS 1910.94, 1910.107,
1910.108.
RTECS #:9999999ZZ
Ingred Name:V M & P NAPHTHA. VP:12
CAS:64742-48-9
Fraction by Wt: 25%
ACGIH TLV:300 PPM (MFR)
Ingred Name:TOLUENE (SARA III). VP::22
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 10%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE. VP:5.9
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: <5%
OSHA PEL:100 PPM; 150 STEL
ACGIH TLV:100 PPM; 150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ISOBUTYL ALCOHOL; (2-METHYL-1-PROPANOL) (SARA III). VP:8.7
CAS:78-83-1
RTECS #:NP9625000
Fraction by Wt: <5%
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETIC ACID, ISOBUTYL ESTER; (ISOBUTYL ACETATE) (SARA
III). VP:12.5
CAS:110-19-0
RTECS #:AI4025000
Fraction by Wt: 25%
OSHA PEL:150 PPM
ACGIH TLV:150 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (TALC)
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 15%
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:VOLATILE ORGANIC COMPOUNDS: 5.69 LB, 681 GM
RTECS #:9999999VO
Ingred Name:SUPP DATA: APPROP HLEATH PROFESSIONALS CONCERNING LATEST
HAZ LIST INFO & SAFE HANDLING & EXPOS RECOMMENDATIONS .
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:APPRVD BONDING & GROUNDING PROCEDURES. TRANSFER
ONLY TO APPRVD CONTRS W/COMPLETE & APPROP LABELING. (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF
CHILDREN. INTENTIONAL MISUSE BY DELIB CONCENTRATING/INHALING (ING
11)
RTECS #:9999999ZZ
Ingred Name:ING 10:CONTENTS CAN BE HARMFUL/FATAL. THIS COATING MAY
CONTAIN MATLS CLASSIFED AS NUISANCE PARTICULATES, SUCH AS(ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 11:TITANIUM DIOXIDE OR CALCIUM CARBONATE (SEE ACGIH TLV
LIST, PREFACE & APPENDIX D), WHICH MAY BE PRESENT (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:AT HAZ LEVELS ONLY DURING SANDING/ABRADING OF DRIED
FILM. IF NO SPECIFIC DUSTS ARE LISTED IN INGRED (ING 14)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRIT OF EYES, SKIN & RESP SYS.
MAY CAUSE NERV SYS DEPRESS. EXTREME OVEREXPOS MAY RSLT IN UNCON &
POSS DEATH. SIGNS/SYMPS OF OVEREXPOS MAY INCL HDCH, DIZZ, NAUS &
LOSS OF COORD AND ARE INDICATI ONS OF EXCESSIVE EXPOS TO VAPS/SPRAY
MISTS. REDNESS & ITCHING OR BURNING SENSATION MAY INDICATE EYE
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:OR EXCESSIVE SKIN EXPOS. CHRONIC:
PRLNGD OVEREXPOS TO SOLV INGREDS IN INGRED SECTION MAY CAUSE
ADVERSE EFTS OF THE LIVER, URINARY, BLOOD FORMING, CARDIO-VASCULAR
& REPROD SYS. RPTS HAVE ASSOC RPTD/PRLNGD OVEREXPOS TO SOLVS
W/PERM BRAIN & NERV SYS DAM. NOTE:TOLUENE 108-88-3 APPEARS ON THE
NAVY LISTING (SUP DAT)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL:IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE BREATHING.
KEEP WARM & QUIET. SKIN:WASH AFFECTED AREA THOROUGHLY W/SOAP &
WATER. REMOVE CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE.
EYES:FLUSH W/LARG E AMOUNTS OF WATER FOR AT LEAST 15 MINS. GET
MEDICAL ATTENTION. INGEST:NEVER GIVE ANYTHING BY MOUTH TO AN UNCON
PERSON. DO NOT INDUCE VOMITING. GIVE SEVERAL GLASSES OF WATER. SEEK
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:45F,7.2C
Lower Limits:0.9%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL & FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER SPRAY MAY BE INEFT. IF WATER IS USED, FOG NOZZ ARE PREF.
WATER MAY BE USED TO COOL CLSD (SUP DAT)
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY CLSD. ISOLATE FROM
HEAT/ELEC EQUIP/SPARKS/OPEN FLAME. CLSD CONTRS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. APPLICATN TO HOT SURF (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE &
REMOVE W/INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTENTS ARE FLAMM. KEEP AWAY FROM
HEAT/SPARKS/OPEN FLAME. KEEP CONTR CLSD WHEN NOT IN USE. USE ONLY
W/ADEQ VENT. AVOID BRTHG VAP/SPRAY MIST.
Other Precautions:AVOID CONT W/SKIN & EYES. DURING USE/UNTIL ALL VAPS
ARE GONE:KEEP AREA VENTD. DO NOT SMOKE. EXTING ALL FLAMES, PILOT
LIGHTS & HEATERS. TURN OFF STOVES, ELEC TOOLS & APPLIANCES & ANY
OTHER SOURCS OF IG NIT. CONSULT NFPA CODE. USE (ING 9)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIMITS BY VENT, WEAR A PROPERLY FITTED NIOSH/MSHA APPRVD ORG
VAP/PARTICULATE RESP FOR PROT AGAINST MATLS IN INGRED SECTION. WHEN
SANDING/ABRADING DR IED FILM, WEAR A NIOSH/MSHA (ING 16)
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPTABLE IF EXPOS TO MATLS IN
INGRED SECTION IS MAINTAINED BELOW APPLIC EXPOS (ING 17)
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC:CONTRS TO PVNT PRESS BUILD-UP & POSS AUTOIGNITION OR
EXPLOS WHEN EXPOSED TO EXTREME HEAT. EXPLO HAZ:REQS SPEC PRECS.
DURING EMER CNDTNS OVEREXPOS TO DECOMP PRODS MAY CAUSE A HLTH HAZ.
SYMPS MAY NOT BE IMMED APPARENT. OBTAINMED ATTN. EFTS OF OVEREXP:OF
OCCUP CHEMICAL REPRODUCTIVE HAZARDS. CONSULT(ING 8)
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:>222F,>106C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:1.03
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:84
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE:CARBON DIOXIDE & CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THIS PROD MAY BE HAZ AS DEFINED UNDER
THE RCRA 40CFR261. WASTE MUST BE TESTED FOR IGNITABILITY TO DETERM
APPLIC EPA HAZ WASTE NOS. INCIN IN APPRVD FACILITY. DO NOT INCIN
CLSD CONTR. DISP OF I/A/W FED, STATE & LOC REGS REGARDING
POLLUTION.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:IL-000 SERIES INDUSTRIAL LACQUER, IL107
Kit Part:Y
CAGE:FO883
CAGE:FO883
CAGE:76708
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPYL ALCOHOL (SARA III). VP:33MM @ 20C.
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 5-10%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM/500STEL
Ingred Name:ETHANOL, 2-BUTOXY-; (2-BUTOXYETHANOL) (SARA III). VP:0.6 @
20C.
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 25-45%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM
Ingred Name:SOLVENT NAPHTHA-; (HEAVY AROMATIC NAPHTHA). VP:5 @ 200F
CAS:64742-94-5
RTECS #:WF3100000
Fraction by Wt: 0-18%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC CONTENT:618 G/L; 5.2 LB/GAL.
RTECS #:9999999VO
Fraction by Wt: 74%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ANIMAL STUDIES HAVE CLEARLY
DEMONSTRATED DOSE-RELATED ADVERSE EFTS ON THE CNS, HEMATOPOIETIC
TISS, BLOOD, KIDNEYS & LIVER ASSOC W/ADMIN OF ETHYLENE GLYCOL
MONOBUTYL ETHER (EGBE). (EXTRACTED FROM DHHS (NIOSH) PUB NO.
90-118) . ACUTE:INHAL:ANESTHETIC. IRRIT OF RESP TRACT/ACUTE NERV
SYS DEPRESS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:CHARACTERIZED BY HEADACHE, DIZZINESS,
STAGGERING GAIT, CONFUSION, UNCONSCIOUSNESS/COMA. SKIN OR EYE
CONT:PRIMARY IRRITATION. RPTD & PRLNGD OVEREXPOSURE OF INHALATION
OR SKIN ABSORPTION MAY CA USE KIDNEY, LIVER, AND BLOOD DAMAGE.
======================= First Aid Measures =======================
First Aid:INHAL:FUMES:REMOVE FROM EXPOSURE. RESTORE BRTHG. KEEP WARM &
QUIET. NOTIFY PHYS. EYES:FLUSH IMMED W/COPIOUS QUANTITIES OF
RUNNING WATER FOR AT LEAST 15 MINUTES. TAKE TO PHYS FOR DEFINITIVE
MED TREATME NT. SKIN:REMOVE W/SOAP & WATER. REMOVE CONTAMD
CLOTHING. INGEST:DO NOT INDUCE VOMITING IF SWALLOWED.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:60.0F,15.6C
Lower Limits:2.0%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:NOT APPLICABLE. WEAR NIOSH/MSHA APPROVED SCBA
& FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPARKS, & OPEN FLAME. CLSD CNTNRS MAY EXPLO WHEN
EXPOS TO EXTREME HEAT. DO NOT APPLY TO HOT (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION (FLAMES, HOT
SURFACES, & ELECTRICAL, STATIC/FRICTIONAL SPARKS). AVOID BREATHING
VAPORS. VENTILATE AREA. REMOVE W/INERT, ABSORBENT AND NON-SPARKING
TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. STORE LG QTYS
IN BUILDINGS DESIGNED FOR STORAGE OF NFPA CLASS IC FLAMM LIQUIDS.
DO NOT TAKE INTERNALLY.
Other Precautions:CNTNRS SHOULD BE GROUNDED WHEN POURING. AVOID FREE
FALL OF LIQUIDS IN EXCESS OF FEW INCHES. DO NOT FLAME CUT, BRAZE,
OR WELD WITHOUT MSHA OR NIOSH APPROVED RESPIRATOR OR APPROPRIATE
VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VAP CONC EXCEEDS TLV LISTED IN INGREDS, USE
NIOSH/MSHA APPRVD RESPIRATORY W/ORGANIC CHEMICAL CARTRIDGE. CONSULT
REPUTABLE SAFETY SUPPLY COMPANY FOR PROPER RESPIRATOR SELECTION.
Ventilation:PROVIDE GEN DILUTION/LOC EXHAUST VENT IN VOL & PATTERN TO
KEEP TLV OF MOST HAZ INGRED BELOW ACCEPTABLE LIM, (SUPDAT)
Other Protective Equipment:PREVENT PROLONGED SKIN CONTACT
W/CONTAMINATED CLOTHING.
Work Hygienic Practices:WASH W/SOAP & WATER BEFORE EATING, SMOKING, OR
USING TOILET FACILITIES.
Supplemental Safety and Health
EXPLO HAZ:SURF. WATER SPRAY MAY BE INEFCTIVE. WATER MAY BE USED TO COOL
CLSD CNTNRS TO PVNT PRESS BUILDUP & POSS AUTOIGNIT/EXPLOS EXPO TO
EXTREME HEAT. IF WATER IS USED, FOG NOZZ ARE PREF. VENT:LEL IN
INGREDS STATED LIM, & TO REMOVE DECOMPPROD DURING WELDING/FLAME
CUTTING ON SURFACES COATED W/THIS PRODUCT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>180F,>82C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:SEE INGRED
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NOT KNOWN
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SEEING
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:MAY PRODUCE HAZ FUMES WHEN HEATED TO
DECOMP AS IN WELDING. FUMES MAY CONTAIN CARBON MONOXIDE & OXIDES OF
NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL,
COUNTY, STATE AND FEDERAL REGULATIONS. DO NOT INCINERATE CLOSED
CONTAINERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SCOTTS LAWN PRO LAWN FERTLIZER (W/S), 21-3-
CAGE:DO909
CAGE:DO909
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIUM SULFATE (SOLUTION) (SARA III)
CAS:7783-20-2
RTECS #:BS4500000
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMMONIUM PHOSPHATE MONOBASIC
CAS:7722-76-1
Other REC Limits:NONE RECOMMENDED
Ingred Name:UREA
CAS:57-13-6
RTECS #:YR6250000
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM CHLORIDE
CAS:7447-40-7
RTECS #:TS8050000
Other REC Limits:NONE RECOMMENDED
Ingred Name:FERROUS SULFATE (SARA III)
CAS:7782-63-0
RTECS #:NO8510000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG FE/M3
ACGIH TLV:1 MG FE/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RAT LD50:
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE EYE IRRITATION. POSSIBLE
NAUSEA, VOMITING, DIARRHEA IF INGESTED. POSSIBLE SKIN IRRITATION.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:MAY CAUSE EYE, SKIN IRRITATION. MAY ALSO CAUSE
HEADACHE, DIZZINESS AND NAUSEA. ASPIRATION PNEUMONITIS MAY CAUSE
COUGHING, LABORED BREATHING, CYANOSIS, AND IN SEVERE CASES, DEATH.
Medical Cond Aggravated by Exposure:NA
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES. IF IRRITATION
PERSISTS, SEE PHYSICIAN. SKIN: WASH WITH SOAP AND WATER. INGESTION:
INDUCE VOMITING IF LARGE AMOUNTS INGESTED. TREAT SYMPTOMATIC AND
SUPPORTIVE.
===================== Fire Fighting Measures =====================
Flash Point:NA
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:USE DRY CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:SULFUR DUST CAN FORM EXPLOSIVE MIXTURES
WITH AIR. IF PRODUCT IS CONSUMED IN A FIRE, TOXIC SULFUR DIOXIDE
WILL FORM.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP SPILLS. USE GOOD HOUSEKEEPING
PRACTICES. AVOID CONTACT WITH SKIN, EYES, OR CLOTHING. WASH AFTER
HANDLING.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP
CONTAINERS CLOSED WHEN MATERIAL IS NOT IN USE. KEEP AWAY FROM FEED
OR FOODSTUFFS.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NA
Ventilation:NA
Other Protective Equipment:NA
Work Hygienic Practices:NA
Supplemental Safety and Health
NA
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NA
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:NA
Evaporation Rate & Reference:NA
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRANULAR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NA
Stability Condition to Avoid:NA
Hazardous Decomposition Products:UREA AND METHYLENE UREA NIGTORGEN
SOURCES CAN GENERATE AMMONIA IN A FIRE.
==================== Disposal Considerations ====================
Waste Disposal Methods:REMOVE TO APPROVED LANDFILL. CITY, STATE AND
FEDERAL REGULATIONS MUST BE FOLLOWED.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ETHYL ALCOHOL, DENATURED (A407) A40720003
Resp. Party Other MSDS Num.:08701
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ALCOHOL; LC50 (INHAL, MOUSE): 39 GM/M3/4H; LC50
(INHAL, RAT): 20000 PPM/10H; LD50 (ORAL, MOUSE): 3450 MG/KG; LD50
(ORAL, RABBIT): 6300 MG/KG; LD50 (ORAL, RAT): 7060 MG/KG
CAS:64-17-5
RTECS #:KQ6300000
Minumum % Wt:85.4
Maxumum % Wt:92.
Other REC Limits:N/K
OSHA PEL:1900 MG/M3;1000 PPM
OSHA STEL:N/K
ACGIH TLV:1880 MG/M3;1000 PPM
ACGIH STEL:N/K
Ingred Name:METHYL ALCOHOL; LC50 (INHAL, RAT): 64000 PPM/4H; LD50
(ORAL, MOUSE): 7300 MG/KG; LD50 (ORAL, RABBIT): 14200 MG/KG; LD50
(ORAL, RAT): 5628 MG/KG; LD50 (SKIN, RABBIT): 15800 MG/KG
CAS:67-56-1
RTECS #:PC1400000
= Wt:3.6
Other REC Limits:N/K
OSHA PEL:260 MG/M3;200 PPM
OSHA STEL:N/K
ACGIH TLV:262 MG/M3;200 PPM
ACGIH STEL:328 MG/M3;250 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPYL ALCOHOL; LD50 (ORAL, MOUSE): 3600 MG/KG; LD50
(ORAL, RABBIT): 6410 MG/KG; LD50 (ORAL, RAT): 5045 MG/KG; LD50
(SKIN, RABBIT): 12800 MG/KG
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 25% PPM
Other REC Limits:N/K
OSHA PEL:980 MG/M3;400 PPM
OSHA STEL:N/K
ACGIH TLV:983 MG/M3;400 PPM
ACGIH STEL:1230 MG/M3;500 PPM
Ingred Name:ACETONE; LC50 (INHAL, RAT): 50100 MG/M3/H8; LD50 (ORAL,
MOUSE): 3 GM/KG; LD50 (ORAL, RABBIT): 5340 MG/KG; LD50 (ORAL, RAT):
5800 MG/KG; LD50 (SKIN, RABBIT): 20 GM/KG
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 2% PPM
Other REC Limits:N/K
OSHA PEL:2400 MG/M3;1000 PPM
OSHA STEL:N/K
ACGIH TLV:1780 MG/M3;750 PPM
ACGIH STEL:2380 MG/M3;1000 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:BENZENE; LC50 (INHAL, MOUSE): 9980 PPM; LC50 (INHAL, RAT):
10000 PPM/7H; LD50 (ORAL, MOUSE): 4700 MG/KG; LD50 (ORAL, RAT): 930
MG/KG; LD50 (SKIN, RABBIT): >9400 MG/KG
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: TRACE
Other REC Limits:N/K
OSHA PEL:10 PPM
OSHA STEL:N/K
ACGIH TLV:32 MG/M3;10 PPM
ACGIH STEL:N/K
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:ACETALDEHYDE; LC50 (INHAL, RAT): 24 GM/M3/4H; LD50 (ORAL,
RAT): 661 MG/KG; LD50 (SKIN, RABBIT): 3540 MG/KG
CAS:75-07-0
RTECS #:AB1925000
Fraction by Wt: 10% PPM
Other REC Limits:N/K
OSHA PEL:360 MG/M3;200 PPM
OSHA STEL:N/K
ACGIH TLV:25 PPM
ACGIH STEL:C45 MG/M3;C25 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL ISOBUTYL KETONE; LC50 (INHAL, MOUSE): 23300 MG/M3;
LD50 (ORAL, MOUSE): 2671 MG/KG; LD50 (ORAL RAT): 2080 MG/KG; LD50
(SKIN, RABBIT): >20 GM/KG
CAS:108-10-1
RTECS #:SA9275000
= Wt:1.9
Other REC Limits:N/K
OSHA PEL:410 MG/M3;100 PPM
OSHA STEL:N/K
ACGIH TLV:205 MG/M3;50 PPM
ACGIH STEL:307 MG/M3;75 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TOLUENE; LC50 (INHAL, MOUSE): 400 PPM/24H; LC50 (INHAL,
RAT): 49 GM/M3/4H; LD50 (ORAL, RAT): 636 MG/KG; LD50 (SKIN,
RABBIT): 12124 MG/KG
CAS:108-88-3
RTECS #:XS5250000
= Wt:.8
Other REC Limits:N/K
OSHA PEL:see Table Z-2
OSHA STEL:N/K
ACGIH TLV:188 MG/M3;50 PPM
ACGIH STEL:N/K
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL ACETATE; LC50(INHAL, MOUSE): 45 GM/M3/2H; LC50(INHAL,
RAT): 200 GM/M3; LD50(ORAL, MOUSE): 4100 MG/KG; LD50(ORAL, RABBIT):
4935 MG/KG; LD50(ORAL, RAT): 5620 MG/KG; LD50(SKIN, RABBIT): >20
GM/KG
CAS:141-78-6
RTECS #:AH5425000
= Wt:1.3
Other REC Limits:N/K
OSHA PEL:1400 MG/M3;400 PPM
OSHA STEL:N/K
ACGIH TLV:1440 MG/M3;400 PPM
ACGIH STEL:N/K
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WATER; LD50 (ORAL, RAT): >90 ML/KG
CAS:7732-18-5
RTECS #:ZC0110000
= Wt:5.
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:LIGHT ALIPHATIC SOLVENT NAPHTHA (PETROLEUM); (SOLVENT
NAPHTHA (PETROLEUM), LIGHT ALIPHATIC)
CAS:64742-89-8
> Wt:.72
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: PRDCES IRRIT, CHARACTERIZED BY
BURNING SENSATION, REDNESS, TEARING, INFLAMM, & POSS CORNEAL
INJURY. MAY CAUSE PAINFUL SENSIT TO LIGHT. VAPS MAY CAUSE IRRIT.
SKIN: MAY CAUSE IRRIT. PRLNG &/OR RPT D CONT MAY CAUSE DEFAT &
DERM. MAY BE ABSORBED THRU SKIN. INGEST: MAY BE FATAL/CAUSE
BLINDNESS IF SWALLOWED. MAY CAUSE SYSTEMIC TOXICITY W/ACIDOSIS. MAY
CAUSE LIVER & KIDNEY DMG. MAY CAUSE CNS DEPRESS , CHARACTERIZED BY
EXCITEMENT, FOLLOWED BY HDCH, DIZZ, DROW, & NAUS. ADVANCED STAGES
MAY CAUSE COLLAPSE, UNCON, COMA & POSS DEATH DUE TO RESP FAILURE.
INHAL: INHAL OF HIGH CONCS MAY CAUSE CNS EFTS CHA RACTERIZED BY
HDCH, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:ISOPROPYL ALCOHOL: IARC: GROUP 3 CARCIN.
BENZENE: ACGIH: A1-CONFIRMED HUMAN CARCIN; CALIFORNIA:
CARCIN-INITIAL DATE 2/27/87; NIOSH: OCCUP CARCIN; NTP: KNOWN
CARCIN; OSHA: SELECT CARCIN; IARC: GRP 1 CA RCIN. ACETALDEHYDE:
ACGIH: A3-ANIMAL CARCIN; CALIFORNIA: CARCIN-INITIAL DATE 4/1/88;
NIOSH: OCCUP CARCIN; NTP: SUSPECT CARCIN; OSHA: POSS SELECT (SUP
DAT)
Effects of Overexposure:HLTH HAZ: DIZZ, UNCON & COMA. MAY CAUSE RESP
TRACT IRRIT. MAY CAUSE EFTS SIMILAR TO THOSE DESCRIBED FOR INGEST.
MAY CAUSE DROW, UNCON, & CNS DEPRESS. CHRONIC: CHRONIC INHAL &
INGEST MAY CAUSE EFTS SIM ILAR TO THOSE OF ACUTE INHAL & INGEST.
PRLNG/RPTD SKIN CONT MAY CAUSE DEFAT & DERM. PRLNG/RPTD EXPOS MAY
CAUSE ADVERSE REPRO EFTS. MAY CAUSE FETAL EFTS. TOLUENE & BENZENE
APPEAR ON THE NAVY OCCUP CHEM REPRO HAZ LIST. SEEK CONSULTATION
FROM APPROP HLTH PROFESSIONALS CONCERNING LATEST HAZ LIST INFO &
SAFE HNDLG & EXPOS INFO .
======================= First Aid Measures =======================
First Aid:EYES: IMMED FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINUTES,
OCCASIONALLY LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. SKIN:
GET MED AID. IMMED FLUSH SKIN W/PLENTY OF SOAP & WATER FOR AT LEAST
15 MI NUTES WHILE REMOVING CONTAMINATED CLOTHING & SHOES. INGEST:
IF CONSCIOUS & ALERT, GIVE 2-4 CUPFULS OF MILK/WATER. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. GET MED AID. INDUCE
VOMITING BY GIVING 1 TEASPOON OF SYRUP OF IPECAC. INHAL: GET MED
AID IMMED. REMOVE FROM EXPOS TO FRESH AIR IMMED. IF NOT BREATHING,
GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, GIVE
OXYGEN. NOTES TO M D: TREAT SYMPTOMATICALLY & SUPPORTIVELY.
===================== Fire Fighting Measures =====================
Flash Point:=13.9C, 57.F
Autoignition Temp:=362.8C, 685.F
Lower Limits:3.3% (ING 1)
Upper Limits:19% (ING 1)
Extinguishing Media:USE WATER SPRAY, DRY CHEMICAL, CHEMICAL FOAM OR
ALCOHOL-RESISTANT FOAM. FOR LARGE FIRES, USE DRY CHEMICAL, CARBON
DIOXIDE, ALCOHOL-RESISTANT FOAM, OR WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO COOL FIRE-EXPOSED CONTAINERS. WATER
MAY BE INEFFECTIVE. DO NOT USE STRAIGHT STREAMS OF WATER. COOL
CONTAINERS WITH FLO ODING QUANTITIES OF WATER UNTIL WELL AFTER FIRE
IS OUT.
Unusual Fire/Explosion Hazard:VAPORS MAY FORM EXPLOSIVE MIXTURE WITH
AIR. VAPORS CAN TRAVEL TO A SOURCE OF IGNITION & FLASH BACK.
CONTAINERS MAY EXPLODE IN THE HEAT OF A FIRE. FLAMMABLE LIQUID. MAY
FORM EXPLOSIVE PEROXIDES. VAPORS MAY BE HEAVIER THAN AIR. THEY CAN
SPREAD ALONG GROUND & COLLECT IN LOW OR CONFINED AREAS. NFPA
RATING: NOT PUBLISHED.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTIVE EQUIPMENT AS
INDICATED IN CONTROL MEASURES SECTION. ABSORB SPILL WITH INERT
MATERIAL (E.G., DRY SAND OR EARTH), THEN PLACE INTO A CHEMICAL
WASTE CONTAINER. REMOVE ALL SO URCES OF IGNITION. A VAPOR
SUPPRESSING FOAM MAY BE USED TO REDUCE VAPORS.
======================Handling and Storage ======================
Handling and Storage Precautions:USE W/ADEQ VENT. GROUND & BOND
CONTAINERS WHEN TRANSFERRING MATL. AVOID CONT W/EYES, SKIN, &
CLOTHING. EMPTY CONTAINERS RETAIN PROD RESIDUE (LIQUID &/OR VAPOR),
& CAN BE DANGEROUS. KEEP CONTAINER TIGH TLY CLOSED. AVOID CONT
W/SKIN, EYES & CLOTHING. AVOID INGEST & INHAL.
Other Precautions:DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL,
GRIND/EXPOSE EMPTY CONTRS TO HEAT, SPKS/OPEN FLAMES. KEEP AWAY FROM
HEAT, SPKS, & FLAME. KEEP AWAY FROM SOURCES OF IGNIT. STORE IN
TIGHTLY CLSD CONT RS. STORE IN COOL, DRY, WELL-VENTILATED AREA AWAY
FROM INCOMPATIBLE SUBSTANCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
29 CFR 1910.134 OR EUROPEAN STANDARD EN 149. ALWAYS USE A NIOSH OR
EUROPEAN STANDARD EN 149 APPROVED RESPIRATOR WHEN NECESSARY.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
AIRBORNE CONCENTRATIONS BELOW THE PERMISSIBLE EXPOSURE LIMITS.
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT
SKIN EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
CARCIN: CARCIN; IARC: GRP 2B CARCIN. TOLUENE: IARC: GRP 3 CARCIN. WASTE
DISP METH: CAS# 67-64-1: WASTE # U002 (IGNIT WASTE). CAS# 71-43-2:
WASTE # U019 (IGNIT WASTE; TOX WASTE). CAS# 75-07-0: WASTE. C AS#
67-56-1, 67-64-1 & 71-43-2 ARE BANNED FROM LAND DISP ACCORDING TO
RCRA. CAS# 75-07-0 IS BANNED.
================== Physical/Chemical Properties ==================
Boiling Pt:=78.5C, 173.3F
Melt/Freeze Pt:=-90.C, -130.F
Vapor Pres:25 MM HG
Vapor Density:1.6(ING 1)
Spec Gravity:0.7905
Viscosity:NOT AVAILABLE
Evaporation Rate & Reference:2.0
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID WITH AROMATIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ISOPROPANOL IS SUSCEPTIBLE TO AUTOXIDATION & THEREFORE SHOULD BE
CLASSIFIED AS PEROXIDIZABLE, ACIDS (MINERAL, NON-OXIDIZING, E.G.
HYDROCHLORIC, HYDROFLUORIC, MURIATIC, PHOSPHORIC, NITRIC & SULFURIC
ACIDS), ACIDS (ORG, E.G.
Stability Condition to Avoid:THIS MATERIAL MAY BE SENSITIVE TO PEROXIDE
FORMATION, INCOMPATIBLE MATERIALS, IGNITION SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
=================== Toxicological Information===================
Toxicological Information:REPRO EFTS: PRENATAL EXPOS TO ETHANOL IS
ASSOC W/DISTINCT PATTERN OF CONGENITAL MALFORMATIONS THAT HAVE BEEN
COLLECTIVELY TERMED FETAL ALCOHOL SYNDROME. AMONG CHARACTS OF THIS
SYNDROME ARE INTRAUTERIN E & POSTNATAL GROWTH DEFICIENCY, A
DISTINCTIVE PATTERN OF PHYSICAL MALFORMATION, &
BEHAVIORAL/COGNITIVE IMPAIRMENT SUCH AS FINE MOTOR DYSFUNCTION &
MENTAL RETARDATION. NOT ALL AFFECTED CHILDREN HAVE A LL OF FEATURES
OF SYNDROME. THIS SYNDROME HAS BEEN ASSOC W/ALCOHOLIC WOMEN WHO
DRANK HEAVILY & CHRONICALLY DURING PREGNANCY.
EPIDEMIOLOGY/TERATOGENICITY/NEUROTOX/MUTAGENICITY/OTHER STUDIES: NO
DATA AV AIL. CONT NEHC FOR MORE INFO .
===================== Ecological Information =====================
Ecological:ECOTOXICITY: 250 PPM/6HR/GOLDFISH/LETHAL/FRESH WATER.
ENVIRON FATE: ETHANOL: IN WATER, WILL VOLATILIZE & PROBABLY
DEGRADE. PHYSICAL/CHEM: NOT AVAIL. OTHER: NOT EXPECTED TO
BIOCONCENTRATE IN FISH. OTHE R INFO: (E.G. ALUMINUM CARBIDE,
CHLOROSILANE, HYDROGEN PHOSPHIDE, LITHIUM HYDRIDE), WATER REACTIVE
SUBSTANCES (E.G. ACETIC ANHYDRIDE, ALKYL ALUMINUM CHLORIDE, CALCIUM
CARBIDE, ETHYL DICHLOROSILANE).
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT W/FED, STATE,
& LOC REGS. RCRA D-SERIES MAX CONC OF CONTAMINANTS: CAS# 71-43-2:
WASTE # D018; REG LEVEL=0.5 MG/L. RCRA D-SERIES CHRONIC TOX
REFERENCE LEVELS: CAS# 71- 43-2: CHRONIC TOX REFERENCE LEVEL=0.005
MG/L. RCRA F/P-SERIES: NONE LISTED. RCRA U-SERIES: CAS# 67-5 6-1:
WASTE # U154 (IGNIT WASTE). (SUP DAT)
=================== MSDS Transport Information ===================
Transport Information:US DOT: SHIPPING NAME: ETHANOL SOLNS; HAZ CLASS:
3; UN #: UN1170; PACKING GRP: II. IMO/IATA/RID/ADR: NO INFO AVAIL.
FED REGS: CLEAN WATER ACT: CAS# 71-43-2/75-07-0/108-88-3: LISTED AS
HAZ SUBSTANCES U NDER CWA; CAS# 71-43-2/108-88-3: LISTED AS
PRIORITY POLLUTANT UNDER CWA; CAS# 71-43-2/108-88-3: LISTED AS TOX
POLLUTANTS UNDER CWA. OSHA: CAS# 75-07-0 CONSIDERED HIGHLY HAZ BY
OSHA. EUROPEAN LABELING I/A/W EC DIRECTIVES: HAZ SYMBOLS: F; RISK
PHRASES: R 11 HIGHLY FLAM; SFTY PHRASES: S 16 KEEP AWAY FROM
SOURCES OF IGNIT-NO SMKNG; S 2 KEEP OUT OF REACH OF CHILDREN; S 7
KEEP CONTR TIGHTLY CLSD. CONT N EHC FOR MORE INFO .
===================== Regulatory Information =====================
SARA Title III Information:SECTION 302(FINAL RQ):CAS#
67-56-1/67-64-1/108-10-1/141-78-6:5000LBS(2270KG);CAS#
71-43-2:10LBS(4.54KG), RECEIVES ADJUSTABLE R; CAS#
75-07-0/108-88-3:1000LBS(454KG). NONE OF CHEMS HAVE TPQ (SECTION 30
2). SARA CODES:CAS# 64-17-5/67-63-0/71-43-2:ACUTE, CHRONIC, FLAM;
CAS# 67-56-1/108-88-3:ACUTE, FLAM; CAS# 67-64-1:ACUTE, CHRONIC,
FLAM, SUDDEN RELEASE OF PRESS; CAS# 75-07-0/108-10-1:ACUTE,
CHRONIC, F LAM. REACTIVE; CAS# 141-78-6:FLAM. SECTION 313:CAS#
67-56-1/67-63-0/75-07-0/108-10-1:SUBJECT TO REPORTING REQS OF
SECTION 313 OF SARA TITLE III & 40 CFR PART 373. CAS#
67-63-0/108-10-1:CONCS TOO LOW T O BE REPORTABLE UNDER SECTION 313.
Federal Regulatory Information:ALL INGS ARE LISTED ON TSCA INVENTORY.
HLTH & SFTY REPORTING LIST: CAS# 67-63-0: EFFECTIVE DEC 15, 1986,
SUNSET DEC 15, 1996; CAS# 108-10-1/108-88-3: EFFECTIVE OCTOBER 4,
1982, SUNSET OCTOBER 4, 1992. CHEM TEST RULES: CAS# 67-63-0:
TESTING REQUIRED BY MFRS, IMPORTERS, PROCESSOR. SECTION 12B: CAS#
67-63-0/67-64-1/108-10-1/141-78-6: EXPORT NOTIFICATION
REQUIRED-SECTION 4. TSCA SIGNIFICANT NEW USE RU LE : NONE OF CHEMS
HAVE SNUR UNDER TSCA. CLEAN AIR ACT: CAS#
67-56-1/71-43-2/75-07-0/108-10-1/108-88 -3: LISTED AS HAZ AIR
POLLUTANTS (HAP). MATL DOES NOT CONTAIN ANY CLASS 1 OR 2 OZONE
DEPLETORS. (TRANSPORT INFO)
State Regulatory Information:ETHYL ALCOHOL, METHYL ALCOHOL, ISOPROPYL
ALCOHOL, ACETONE, BENZENE, ACETALDEHYDE, METHYL ISOBUTYL KETONE,
TOLUENE & ETHYL ACETATE CAN BE FOUND ON THE FOLLOWING STATE
RIGHT-TO-KNOW LISTS: CA, NJ, FL, P A, MN, MA. WATER & SOLV NAPHTHA
(PETRO) LIGHT ALIPHATIC ARE NOT PRESENT ON STATE LISTS FROM CA, PA,
MN, MA, FL/NJ. WARNING: BENZENE IS KNOWN TO STATE OF CA TO CAUSE
CANCER, BIRTH DEFECTS/OTHER REPRO H ARM; ACETALDEHYDE IS KNOWN TO
STATE OF CA TO CAUSE CANCER; ETHYL ALCOHOL IS KNOWN TO STATE OF CA
TOCAUSE BIRTH DEFECTS/OTHER REPRO HARM. CA NO SIGNIFICANT RISK
LEVEL: CAS# 71-43-2=7 UG/DAY; CAS# 75-07-0: INHAL=90 UG/DAY.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PRIMARY BATTERY,MERCURY NR6
CAGE:S7424
CAGE:4J627
CAGE:S7424
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM HYDROXIDE (SARA III).BP 2408F;VP 1 MMHG @ 719F.
CAS:1310-58-3
RTECS #:TT2100000
Other REC Limits:NONE SPECIFIED
OSHA PEL:2 MG/M3 CEILING
ACGIH TLV:2 MG/M3 CEILING
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:MERCURIC OXIDE (SARA III).OSHA PEL IS CEILING VALUE.
CAS:21908-53-2
RTECS #:OW8750000
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.1 MG(HG)/M3 SKIN
ACGIH TLV:0.1 MG(HG)/M3 SKIN
Ingred Name:MERCURY (SARA III).BP 674F;VP 188C.OSHA PEL IS CEILING
VALUE FOR INORGANIC MERCURY COMPOUNDS.
CAS:7439-97-6
RTECS #:OV4550000
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.1 MG(HG)/M3 SKIN
ACGIH TLV:0.05 MG/M3 SKIN
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT KNOWN
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS AND SYMPTOMS OF
OVEREXPOSURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:LIQUID FROM LEAKING BATTERY MAY BE HARMFURL.
POTASSIUM HYDROXIDE IS CAUSTIC.EYES:CONTACT WITH LIQUID MAY BE
CORROSIVE TO EYES.SKIN:CONTACT WITH LIQUID MAY BE CORROSIVE TO
SKIN.
Medical Cond Aggravated by Exposure:NOT KNOWN
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST 15
MINUTES AND SEE PHYSICIAN. SKIN:REMOVE LIQUID IMMEDIATELY WITH
WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:NOT KNOWN
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS WHEN
BATTERIES ARE IN FIRE.
Unusual Fire/Explosion Hazard:CAN EXPLODE WHEN SUBJECTED TO EXCESSIVE
HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID SKIN AND EYE CONTACT.
Neutralizing Agent:NOT KNOWN
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE,IN DRY PLACE
WITH LITTLE TEMERATURE CHANGE.
Other Precautions:DO NOT CHARGE,SHORT-CIRCUIT,DISASSEMBLE,HEAT OR
DISPOSE BATTERIES IN FIRE.INSERT BATTERIES IN CORRECT POLARITY
POSITIONS.DO NOT DIRECTLY SOLDER TO BATTERIES.DO NOT USE SPENT
BATTERIES WITH NEW ONES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CONTACT LOCAL SAFETY/INDUSTRIAL HYGIENE OFFICE
TO DETERMINE IF RESPIRATORY PROTECTION IS REQUIRED .
Ventilation:CONTACT LOCAL SAFETY/INDUSTRIAL HYGIENE OFFICE TO DETERMINE
IF LOCAL EXHAUST VENTILATION IS NEEDED .
Other Protective Equipment:NOT KNOWN
Work Hygienic Practices:NOT KNOWN
Supplemental Safety and Health
DIMENSIONS OF BATTERIES:GROSS WEIGHT (LB): 31;OUTSIDE DIMENSION
(INCHES):14.5 (D),50.0 (H).
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NOT KNOWN
Melt/Freeze Pt:M.P/F.P Text:NOT KNOWN
Decomp Temp:Decomp Text:NOT KNOWN
Vapor Pres:NOT KNOWN
Vapor Density:NOT KNOWN
Spec Gravity:NOT KNOWN
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:NOT KNOWN
Appearance and Odor:POTASSIUM HYDROXIDE:CLEAR LIQUID.MERCURY:SILVER.
MERCURIC OXIDE:ORANGE-RED POWD
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NOT KNOWN
Stability Condition to Avoid:MERCURY OXIDE:LIGHT OR TEMPERATURES ABOVE
500F.
Hazardous Decomposition Products:MERCURIC OXIDE DECOMPOSES ON EXPOSURE
TO LIGHT OR TEMPERATURES ABOVE 500F TO MERCURY AND OXYGEN.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE, AND LOCAL REGULATIONS.COORDINATE WITH SUPPORTING
INSTALLATION AND/OR MACOM ENVIRONMENTAL OFFICE PRIOR TO DISPOSAL
.DO NOT BURN,CAN EXPLODE WHEN SUBJECTED TO EXCESSIVE HEAT.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TIN/LEAD SOLDER, QQ-S-571
CAGE:52329
CAGE:52329
============= Composition/Information on Ingredients =============
Ingred Name:LEAD (SARA III)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 37.5%
OSHA PEL:0.05 MG/M3;1910.1025
ACGIH TLV:0.15 MG/M3;DUST 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
Fraction by Wt: 61.5%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9192
Ingred Name:ROSIN ACID
CAS:8050-09-7
Ingred Name:DIPROPYLENE GLYCOL
CAS:110-98-5
RTECS #:UB8785000
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: METALLIC TASTE ABDOMINAL
PAIN, NAUSEA, JOINT OR MUSCLE PAIN OR WEAKNESS. POSSIBLE LOSS OF
WEIGHT, MENTAL CONFUSION, LEAD LINE ON GUMS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:LEAD POISONING AFTER LONG-TERM EXTREME EXPOSURE
FROM INGESTION OR INHALATION OF COMPOUNDS OR FUMES. METALLIC TASTE
ABDOMINAL PAIN, NAUSEA, JOINT OR MUSCLE PAIN OR WEAKNESS. POSSIBLE
LOSS OF WEIGHT, ME NTAL CONFUSION, LEAD LINE ON GUMS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM AREA; SEE PHYSICIAN. IF BURNED FROM
MOLTEN METAL, GIVE ORDINARY BURN FIRST AID. DON'T ATTEMPT TO REMOVE
ROSIN FROM SECOND OR THIRD DEGREE BURNS. USE SOLVENTS TO REMOVE
ROSIN FR OM MINOR FIRST DEGREE BURNS.
===================== Fire Fighting Measures =====================
Flash Point:CORE: 300F
Extinguishing Media:CORE: SPRAY, FOAM, DRY POWDER, CO2
Fire Fighting Procedures:IN EXTREMELY HIGH TEMP FIRES, LEAD MAY EMIT
TOXIC FUMES. WHEN IN PROXIMITY TO HIGHLY OXIDIZING MATERIALS AT
VERY HIGH TEMPS, LEAD MAY REACT VIGOROUSLY.
Unusual Fire/Explosion Hazard:MODERATE HAZARD WHEN HIGH CONCENTRATION
OF VERY FINE METALLIC DUST IS EXPOSED TO HIGH HEAT OR OPEN FLAME.
HOT LIQUID ROSIN CORE MAY FOAM WITH LIQUID WATER.
================== Accidental Release Measures ==================
Spill Release Procedures:NORMAL HOUSEKEEPING FOR SOLID METAL. METALLIC
POWDER OR DUST SHOULD BE VACUUMED OR WET SWEPT USING A RESPIRATOR
AND PROTECTIVE CLOTHING.
======================Handling and Storage ======================
Handling and Storage Precautions:USE GOOD HOUSEKEEPING PRACTICES TO
PREVENT ACCUMULATIONS OF DUST/TO KEEP AIRBORNE DUST CONCENTRATIONS
AT A MINIMUM. AVOID BREATHING DUST OR FUMES.
Other Precautions:WASH HANDS AFTER HANDLING. DON'T SMOKE OR EXPOSE FOOD
TO DUST. KEEP AREA CLEAN.
============= Exposure Controls/Personal Protection =============
Ventilation:LOCAL EXHAUST: FUME HOOD OVER WORK AREA. MECHANICAL: 200
FT./MIN. AIR VELOCITY INTO HOOD OPENING.
Other Protective Equipment:FACE SHIELD IF DANGER OF SPLASHING, MOLTEN
METAL. SAFETY EYEWASH STATIONS SHOULD BE IN CLOSE PROXIMITY.
Work Hygienic Practices:USE GOOD HOUSEKEEPING PRACTICES TO PREVENT
ACCUMULATIONS OF DUST/TO KEEP AIRBORNE DUST CONCENTRATIONS AT A
MINIMUM.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:CORE: 250F
Spec Gravity:CORE: 1.1
Solubility in Water:INSOLUBLE
Appearance and Odor:CORE: CLEAR SOLID AT ROOM TEMPERATURE WITH LIGHT
ROSIN ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MATERIAL MAY BE INCOMPATIBLE WITH ACIDS, BASES & OXIDIZERS. MOLTEN
METAL MAY REACT VIOLENTLY WITH WATER.
Hazardous Decomposition Products:TEMPERATURE ABOVE THE MELTING POINT
MAY EMIT TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:SCRAP DRIPPINGS & DROSSES SHOULD BE STORED IN A
CLOSED CONTAINER & RETURNED TO A LEAD RECYCLER. FOLLOW FEDERAL,
STATE & LOCAL REGULATIOS REGARDING DISPOSAL.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: NITROGEN DIOXIDE IN NITROGEN 2-50 PPM
Cage: 18260
=======================================================
Contractor Summary
=======================================================
Cage: 18260
=======================================================
Ingredients
=======================================================
Cas: 10102-44-0
RTECS #: QW9800000
H*2O: HYDROLYZES TO NITRIC & NITROUS ACID
OSHA PEL: C 5 PPM
ACGIH TLV: 3 PPM/5 STEL
EPA Rpt Qty: 10 LBS
DOT Rpt Qty: 10 LBS
------------------------------
Cas: 7727-37-9
RTECS #: QW9700000
H*2O: NEGLIGIBLE
OSHA PEL: N/K (FP N)
ACGIH TLV: ASPHYXIANT
------------------------------
OF TIME. DOT 39 CYL MAY NOT BE REUSED/
-----------------------------
VEHICLES, ENCLSD VANS, TRUCK CABS/IN PASSENGER
-----------------------------
PICKUP TYPE VEHICLES.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: EFFECTS OF EXPOSURE TO HIGH CONCENTRATIONS SO AS TO
DISPLACE THE OXYGEN IN THE AIR NECESSARY FOR LIFE ARE HEADACHE, DIZZINESS,
LABORED BREATHING AND EVENTUAL UNCONSCIOUSNESS. CHRONIC: NONE SPEC IFIED BY
MANUFACTURER.
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: PERSONS IN ILL HEALTH WHERE SUCH ILLNESS
WOULD BE AGGRAVATED BY EXPOSURE TO THESE MIXTURES SHOULD NOT BE ALLOWED TO
WORK WITH OR HANDLE THESE PRODUCTS.
First Aid: PROMPT MED ATTN IS MANDATORY IN ALL CASES OF OVEREXP TO THESE MIX.
INHAL: CONSCIOUS PERS SHOULD BE ASSISTED TO UNCONTAM AREA & INHALE FRESH
AIR. QUICK REMOVAL FROM CONTAM AREA IS MOST IMPORTANT. UNCONPERS SHOULD BE
MOVED TO UNCONTAM AREA,GIVEN ASSISTED RESP & SUPPLEMENTAL OXYGEN. FURTHER
TREATMENT SHOULD BE SYMPTOMATIC & SUPPORTIVE. EYES: FLUSH W/POTABLE WATER
FOR AT LEAST 15 MIN. (SUP DAT)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: EVACUATE ALL PERSONNEL FROM AFFECTED AREA. USE
APPROPRIATE PROTECTIVE EQUIPMENT. IF LEAK IS IN CONTAINER OR CONTAINER VALVE,
CONTACT THE CLOSEST MFR LOCATION.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DO NOT ATTEMPT TO DISP OF WASTE/UNUSED QTYS. RETURN IN
SHIPPING CONTR PROPERLY LABELED, W/ANY VALVE PLUGS/CAPS SECURED TO MFR FOR
PROPER DISP. FOR EMER DISP CONT CLOSEST MFR LOCATION. DISPOSE OF I/A/W
LOCAL, STATE & FEDERAL REGULATIONS (FPN).
Handling And Storage Precautions: USE ONLY IN WELL-VENT AREAS. USE PRESS
REDUCING REGULATOR WHEN CONNECTING CYL TO LOWER PRESS (<500 PSIG)
PIPING/SYS.
Other Precautions: DO NOT HEAT CYL BY ANY MEANS TO INCR DISCHARGE RATE OF PROD
FROM CYL. USE CHECK VALVE/TRAP IN DISCHARGE LINE TO PVNT HAZ BACK FLOW INTO
CYL. CLOSE VALVE AFTER EACH USE & WHEN EMPTY. PROT CYL FROM PHYS ICAL
DMG. STORE IN COOL, DRY, (SUP DAT)
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: NON-FLAMMABLE GAS MIXTURES. USE MEDIA SUITABLE FOR
SURROUNDING FIRE (FP N).
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). IF CYLINDERS ARE INVOLVED IN A FIRE, SAFELY RELOCATE OR
KEEP COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard: NONE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH/MSHA APPROVED POSITIVE PRESSURE AIR LINE WITH
MASK OR NIOSH/MSHA APPROVED SCBA SHOULD BE AVAILABLE FOR EMERGENCY USE.
Ventilation: LOC EXHAUST: TO PVNT ACCUM OF HIGH CONCS SO AS TO REDUCE OXYGEN
LEVEL IN AIR TO LESS THAN 18 MOLAR PERCENT.
Other Protective Equipment: SAFETY SHOES. EMERGENCY EYEWASH & DELUGE SHOWER
MEETING ANSI DESIGN CRITERIA (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: FIRST AID PROC:SEE MD (FP N). SKIN: FLUSH
W/COPIOUS AMTS OF WATER. SEE MD (FP N). INGEST: CALL MD IMMED (FP N). OTHER
PREC: WELL-VENT AREA AWAY FROM HEAVILY TRAFFICKED AREAS & EMER EXITS. DO
NOT ALLOW TEMP WHERE CYL ARE STORED TO EXCEED 125F (52C). FULL & EMPTY
CYL SHOULD BE SEGREGATED. USE "FIRST IN-FIRST OUT"
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: SEE INGS
Vapor Pres: SEE INGS
Spec Gravity: 0.97 (AIR=1)
Solubility in Water: SEE INGS
Appearance and Odor: COLORLESS GAS, WITH SLIGHT ACID ODOR
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products: NONE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: NITROGEN DIOXIDE IN NITROGEN 2-50 PPM
Cage: 18260
Company Name: LIQUID AIR CORPONE CALIFORNIA PLAZA
Street: 2121 N. CALIFORNIA BLVD
Zipcode: 94596
Label Required IND: Y
Date Of Label Review: 10/05/1995
Status Code: C
Label Date: 10/05/1995
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: EFFECTS OF EXPOSURE TO HIGH CONCENTRATIONS SO AS
TO DISPLACE THE OXYGEN IN THE AIR NECESSARY FOR LIFE ARE HEADACHE, DIZZINESS,
LABORED BREATHING AND EVENTUAL UNCONSCIOUSNESS. CHRONIC: NONE SPEC IFIED BY
MANUFACTURER.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:EPK (EPS) 608 PART A
Kit Part:Y
Preparer's Name:KEN DECOSTA
CAGE:33564
CAGE:1JB33
CAGE:33564
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, AMORPHOUS (FILLER PARTICLES ARE THOROUGHLY WETTED
BY VEHICLE SO AIRBORNE EXPOSURE DOES NOT OCCUR UNLESS CURED*
CAS:112945-52-5
RTECS #:VV7310000
OSHA PEL:20 MPPCF
Ingred Name:*MATERIAL IS SUBSEQUENTLY GROUND, MACHINED OR SANDED.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:MAY CAUSE SKIN IRRITATION AND POSSIBLE
ALLERGIC REACTIONS. PROLONGED AND REPEATED CONTACT MAY CAUSE
SENSITIZATION WHICH WILL RESULT IN ALLERGIC REACTIONS.
Explanation of Carcinogenicity:N/K *FAILURE TO OBSERVE CAUTION MAY
RESULT IN EXCESSIVE HEAT BUILD-UP WITH THE RELEASE OF TOXIC GASES.
Effects of Overexposure:SKIN/RASH IRRITATION.
======================= First Aid Measures =======================
First Aid:FLUSH SKIN AND EYE CONTACT WITH PLENTY OF WATER. WASH SKIN
THOROUGHLY WITH SOAP AND WATER, RUBBING ALCOHOL OR HAND CLEANER. DO
NOT USE SOLVENTS. REMOVE SOILED CLOTHING AND WASH BEFORE REUSE. IF
IRRITA TION PERSISTS, SEE PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:470F,243C
Extinguishing Media:DRY CHEMICAL OR HALON FIRE EXTINGUISHER, WATER
SPRAY, FOAM OR FOG.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS WHEN
FIGHTING FIRES IN CONFINED AREAS.
Unusual Fire/Explosion Hazard:DENSE SMOKE AND TOXIC GASES MAY BE
LIBERATED.
================== Accidental Release Measures ==================
Spill Release Procedures:SCRAPE UP AND TRANSFER TO METAL CONTAINER.
WIPE UP REMAINING RESIDUE WITH SOLVENTS, OBSERVING SOLVENT
FLAMMABILITY CAUTIONS, OR USE DETERGENT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP COOL IN ACCORDANCE WITH LABEL
INSTRUCTIONS.
Other Precautions:FOLLOW RECOMMENDED CURING SCHEDULE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NEEDED WITH GOOD INDUSTRIAL VENTILATION.
Ventilation:LOCAL EXHAUST RECOMMENDED, MECHANICAL ACCEPTABLE.
Other Protective Equipment:AS NEEDED TO PROTECT SKIN AND CLOTHING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>500
Vapor Pres:<0.1
Vapor Density:NIL
Spec Gravity:1.16
Evaporation Rate & Reference:>1
Solubility in Water:INSOLUBLE
Appearance and Odor:MILKY, HIGH VISCOSITY LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG LEWIS OR MINERAL ACIDS.
Hazardous Decomposition Products:CO, NOX, ALDEHYDES, ACIDS AND
UNDETERMINED ORGANICS.
Conditions to Avoid Polymerization:MIXING RESIN/CURING AGENT IN BATCHES
GREATER THAN 1 LB. DO NOT HEAT MATERIAL UNLESS CURING SURFACES TO
BE BONDED.*
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AS HAZARDOUS WASTE ACCORDING TO DOT
HAZARD CLASS. IF NOT REGULATED BY DOT, DISPOSE OF AS ORM-E.
DISPOSAL METHOD CAN BE LAND BURIAL OR CHEMICAL INCINERATION.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:NA1789, LI'L BROTHER SAM
CAGE:53798
CAGE:53798
============= Composition/Information on Ingredients =============
Ingred Name:HYDROCHLORIC ACID (SARA III)
CAS:7647-01-0
RTECS #:MW4025000
Fraction by Wt: <10%
OSHA PEL:5 PPM, C
ACGIH TLV:5 PPM, C
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPYL ALCOHOL; (ISOPROPANOL) (MFR CAS# 76-63-0)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: <10%
OSHA PEL:400 PPM;500 STEL
ACGIH TLV:400 PPM;500 STEL
Ingred Name:OXALIC ACID
CAS:144-62-7
RTECS #:RO2450000
Fraction by Wt: <2%
OSHA PEL:1 MG/M3;2 PPM STEL
ACGIH TLV:1 MG/M3;2 PPM STEL
Ingred Name:P-TOLUENE SULFONIC ACID; (TOLUENE SULFONIC ACID)
CAS:104-15-4
RTECS #:XT6300000
Fraction by Wt: <5%
Ingred Name:PHOSPHORIC ACID
CAS:7664-38-2
RTECS #:TB6300000
Fraction by Wt: <15%
OSHA PEL:1 MG/M3;3 STEL
ACGIH TLV:1 MG/M3;3 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY BE FATAL IF SWALLOWED. SKIN
AND EYE CONTACT AND BREATHING OF VAPORS MAY PRODUCE CHEMICAL BURNS.
CHRONIC: NO CHRONIC EFFECTS EXPECTED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST: PROMPT FIRST AID & TREATMENT IS ESSNTL IF CONT
OCCURS.CALL PHYS IMMED! DRINK LRG VOL OF H2O TO DILUTE ACID. DO NOT
ATTEMPT TO MAKE PERSON VOMIT. INHAL: REMOVE PERSON TO FRESH AIR.
CONT PHYS. E YES: IMMED FLUSH W/PLENTY OF COOL H2O FOR AT LEAST 15
MIN. SEEK PROMPT MED ATTN. CONT LENSES SHOULD NOT BE WORN WHEN
WORKING WITH PRODUCT. SKIN: WIPE OFF GENTLY. IMMED FLOOD SURFACE
W/H2O, (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:NONE TO 200F
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE CONDITIONS
.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . AVOID POSSIBLE EXPOSURE TO HYDROGEN CHLORIDE
VAPOR.
Unusual Fire/Explosion Hazard:ACID WILL ATTACK MOST METALS WITH
EVOLUTION OF HYDROGEN.
================== Accidental Release Measures ==================
EXCESS LIQUID WITH RAGS OR OIL ABSORBENT. DISPOSE OF CHEMICAL
RECEPTACLE OR DILUTE WITH WATER AND NEUTRALIZE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY CLOSED. KEEP
FROM FREEZING. WARNING: CORROSIVE. CONTAINS ACID. MAY BE FATAL IF
SWALLOWED. DO NOT BREATH VAPOR OR FUMES.
Other Precautions:DO NOT GET IN EYES,ON SKIN/CLTHG. MAY PRDCE CHEM
BURNS. DO NOT USE IN/ALLOW TO SPLASH ON ENAMEL OR GUARANTEED
ACID-RESISTANT METAL. EMPTY CNTNRS & RINSE W/H2O BEFORE DISP.DO NOT
MIX W/ANY OTHER CHEM.A VOID SPLASHING ON NYLON/COTTON. (SUPDAT
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL PROTECTION NEEDED UNDER NORMAL USE
CONDITIONS. IF NEEDED TO STAY BELOW TLV USE A NIOSH/MSHA APPROVED
RESPIRATOR FITTED WITH ACID (HYDROCHLORIC) CARTRIDGES.
Ventilation:USE IN VENTILATED AREAS.
Other Protective Equipment:A SOURCE OF CLEAN WATER SHOULD BE NEARBY IN
CASE OF ACCIDENTAL EYE CONTACT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: USING SOAP FREELY, THEN COVER W/MAGNESIA OR BAKING
SODA. SEEK MEDICAL ATTENTION. OTHER PREC: READ AND FOLLOW ALL LABEL
DIRECTIONS AND PRECAUTIONS BEFORE USING PRODUCT. THESE PRODUCTS A
RE INTENDED FOR INDUSTRIAL AND INSTITUTIONAL USE ONLY. KEEP OUT OF
REACH OF CHILDREN.
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:225F,107C
Spec Gravity:1.152 (H2O=1)
pH:<1.0
Solubility in Water:COMPLETE
Appearance and Odor:A CLEAR, GREEN LIQUID, WITH MINT ODOR.
Percent Volatiles by Volume:80(WT)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
METALS AND STRONG ALKALI, HYDROGEN CHLORIDE VAPOR.
Stability Condition to Avoid:EXTREMELY HIGH TEMPERATURES. DO NOT MIX
WITH OTHER CHEMICALS.
Hazardous Decomposition Products:BURNING PRODUCT MAY PRODUCE HYDROGEN,
CO2 AND OXIDES OF PHOSPHORUS.
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW ALL FEDERAL, STATE AND LOCAL REGULATIONS
REGARDING WASTE DISPOSAL. LARGE QUANTITIES MUST BE DISPOSED OF AS
HAZARDOUS WASTE BECAUSE PH IS LESS THAN 2.5.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DURSBAN 2E INSECTICIDE, PROD CODE:01147
CAGE:96717
CAGE:96717
============= Composition/Information on Ingredients =============
Ingred Name:CHLORPYRIFOS (SARA III)
CAS:2921-88-2
RTECS #:TF6300000
Fraction by Wt: 24.1%
OSHA PEL:S, 0.2 MG/M3
ACGIH TLV:S, 0.2 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:XYLENE RANGE AROMATIC SOLVENT
CAS:64742-95-6
Ingred Name:1,4-DIOXANE (DIETHYLENE DIOXIDE) (SARA III)
CAS:123-91-1
RTECS #:JG8225000
OSHA PEL:S, 100 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:PROPRIETARY EMULSIFIER
Ingred Name:PROPRIETARY SOLVENT
===================== Hazards Identification =====================
LD50 LC50 Mixture:LC50=2.5 MG/L (4 HR,FEMAL RAT).
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES
Health Hazards Acute and Chronic:EYE:CAUSE PAIN,SEVERE IRRITATION;
SKIN:CAUSE BURNS,DRYING OR FLAKING; ING:SINGLE DOSE ORAL TOXICITY
IS LOW,LARGER AMOUNTS MAY CAUSE INJURY,IF ASPIRATED,MAY CAUSE LUNG
DAMAGE,EVEN DEATH TO CHEMICAL PNE UMONIA,CAUSED BY PETROLEUM-LIKE
SOLVENTS; INH:CAUSE EYE & UPPER RESPIRATORY IRRITATION,CENTRAL
NERVE SYS DEPRESSION.
Explanation of Carcinogenicity:1,4-DIOXANE IS A SUSPECTED CARCINOGEN.
Effects of Overexposure:HEADACHE,DIZZINESS,INCOORDINATION,MUSCLE
TWITCHING,TREMORS,NAUSEA,ABDOMINAL
CRAMPS,DIARRHEA,SWEATING,PINPOINT PUPILS,BLURRED
VISION,SALIVATION,TEARING,TIGHTNESS IN CHEST,EXCESSIVE
URINATION,CONVULSION S.
Medical Cond Aggravated by Exposure:BECAUSE RAPID ABSORPTION MAY OCCUR
THROUGH LUNGS IF ASPIRATED & CAUSE SYS EFF,THE DECISION OF WHETHER
TO INDUCE VOMITING SHOULD BE MADE BY A PHYSICIAN.
======================= First Aid Measures =======================
First Aid:EYE/SKIN:FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MIN,WASH
CONTAMINATED CLOTHING,CONTACT PHYSICIAN; ING:DO NOT INDUCE
VOMITING,CALL A PHYSICIAN OR TRANSPORT TO EMERGENCY FACILITY
IMMEDIATELY; INH:IF ILL EFFECTS OCCUR,REMOVE TO FRESH AIR,IF NOT
BREATHING,GIVE ARTIFICIAL RESPIRATION,PREFERRABLY MOUTH-TO-MOUTH,IF
BREATHING IS DIFFICULT,GIVE OXYGEN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:102F/39C
Lower Limits:1.1
Upper Limits:6
Extinguishing Media:FOAM,CO*2,DRY CHEMICAL
Fire Fighting Procedures:FOAM SYSTEM IS PREFERRED,USE POSITIVE PRESSURE
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:TOXIC IRRITATING GASES MAY BE
FORMED.RAPID DECOMPOSITION AT 160-200C.VIOLENT ERUPTION OF
CONTAINERS MAY OCCUR.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SPILLS WITH MATERIAL SUCH AS
SAND,SAWDUST,ZORBALL OR DIRT.CONTAIN SPILL BY DIKING TO KEEP OUT OF
SEWERS.FOR LARGE SPILLS,BARRICADE AREA,ELIMINATE IGNITION SOURCES &
CONSULT MFG.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE AN APPROVED AIR-PURIFYING RESPIRATOR. FOR
EMERGENCY:USE AN APPROVED POSITIVE PRESSURE,SELF-CONTAINED
BREATHING APPARATUS.
Ventilation:MECHANICAL & LOCAL EXHAUST TO CONTROL BELOW TLV.
Other Protective Equipment:SAFETY SHOWER & EYE BATH.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F5
Boiling Pt:B.P. Text:284F/140C
Decomp Temp:Decomp Text:160-200C
Vapor Pres:49MMHG,49C
Vapor Density:<1
Spec Gravity:0.999
Solubility in Water:EMULSIFIABLE
Appearance and Odor:YELLOW LIQUID,NO CRYSTAL POINT, WITH MERCAPTAN
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
BASES,CONSULT MFG FOR SPECIFIC CASES.
Stability Condition to Avoid:AVOID TEMPERATURE ABOVE
122F(50C),CHLORPYRIFOS UNDERGOES EXTHERMIC DECOMPOSITION.
Hazardous Decomposition Products:HYDROGEN CHLORIDE,ETHYL
SULFIDE,DIETHYL SULFIDES & NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:PESTICIDE WASTES ARE TOXIC.IF THESE WASTES CAN
NOT BE DISPOSED OF BY USE ACCORDING TO LABEL INSTRUCTIONS,CONTACT
YOUR STATE PESTICIDE OR ENVIRONMENTAL CONTROL AGENCY OR THE
HAZARDOUS WASTE REPRESENTAT IVE AT THE NEAREST EPA REGIONAL OFFICE
FOR ADVICE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CASTONE - WHITE,GYPSUM,PLASTER OF PARIS
CAGE:EO128
CAGE:49867
CAGE:EO128
============= Composition/Information on Ingredients =============
Ingred Name:PLASTER OF PARIS; CALCIUM SULFATE HEMIHYDRATE
CAS:10034-76-1
RTECS #:EW4150000
OSHA PEL:5 MG/CUM RESP DUST
ACGIH TLV:10 MG/CUM TOTAL DUST
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: SLIGHT IRRITATION. INHALATION:
SLIGHT PAIN TO RESPIRATORY PASSAGE. INGESTION: SMALL AMOUNTS SHOULD
NOT CAUSE INJURY.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MINS. SKIN: WASH OFF.
INHALATION: REMOVE TO FRESH AIR. NEVER GIVE FLUIDS OR INDUCE
VOMITING IF UNCONSCIOUS OR HAVING CONVULSIONS. OBTAIN MEDICAL
ATTENTION IN ALL CA SES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, CO2, FOAM, DRY CHEMICAL
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP MATERIAL TO COLLECT & CONTAIN FOR
SALVAGE OR DISPOSAL. MAY WET DOWN TO MINIMIZE DUST.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN COOL, DRY PLACE.
Other Precautions:AVOID EYE & SKIN CONTACT. DON'T BREATH FUMES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RECOMMENDED
Ventilation:MECHANICAL (GENERAL): RECOMMENDED
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:2.7
Solubility in Water:MODERATE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HIGH TEMPERATURE
Hazardous Decomposition Products:SULFUR OXIDES, TOXIC GAS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PWD,P-D-680 B
CAGE:64662
CAGE:64662
CAGE:3V968
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM METASILICATE
CAS:6834-92-0
RTECS #:VV9275000
Other REC Limits:NONE RECOMMENDED
Ingred Name:2-BUTOXYETHANOL
CAS:111-76-2
RTECS #:KJ8575000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9596
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS UNKNOWN.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, CNS,
RESPIRATORY & GI TRACTS. ACUTE- EYES/SKIN:MAY CAUSE SEVERE
IRRITATION. MAY BE ABSORBED THROUGH SKIN. INHALE:MAY CAUSE
RESPIRATORY TRACT IRRITATION, CNS EFFECTS. ORAL:SEVE RE IRRITATION
OF MUCOUS MEMBRANES. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SEVERE IRRITATION, PAIN, TEARING, NAUSEA,
HEADACHE, DIZZINESS
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. TREAT SYPTOMATICALLY. EYES:FLUSH
WITH WATER FOR 15 MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH
SOAP & WATER. ORAL:DRINK LARGE AMOUNT OF WATER OR MILK. SEEK
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NOT RELEVANT
Upper Limits:NOT RELEVANT
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM/DRY CHEMICAL.
WATER SPRAY MAY BE USED TO KEEP FIRE EXPOSED CONTAINERS COOL.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. HAZARDOUS DECOMPOSITION
PRODUCTS MAY BE FORMED.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROPER PROTECTIVE EQUIPMENT. VENTILATE
AREA. STOP LEAK IF POSSIBLE. ABSORB SPILL WITH VERMICULITE OR SAND.
PLACE IN SEALED CONTAINERS FOR DISPOSAL. WASH AREA WITH SOAPY WATER
AND RINSE.
Neutralizing Agent:ACETIC ACID, CITRIC ACID, DILUTE PHOSPHORIC ACID
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN VENTILATED AREA, AWAY FROM
INCOMPATIBLE MATERIALS. KEEP CONTAINER TIGHTLY CLOSED WHEN NOT IN
USE.
Other Precautions:DO NOT GET IN EYES, ON SKIN, ON CLOTHING. AVOID
BREATHING VAPORS/MIST. USE WITH ADEQUATE VENTILATION. KEEP OUT OF
REACH OF CHILDREN. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY NEEDED. IF EXCESSIVE MISTING IS
EXPECTED, WEAR NIOSH-APPROVED MIST RESPIRATOR (REFER TO 29 CFR
1910.134)
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP FUME OR
MIST LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:SAFETY SHOWER AND EYE WASH FOUNTAIN SHOULD
BE LOCATED NEARBY. WEAR APPROPRIATE PROTECTIVE CLOTHING FOR RISK OF
EXPOSURE.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:C2
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:1.035 - 1.045
pH:12- 13
Evaporation Rate & Reference:1 (WATER=1)
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID - BUTYL ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
UNIDENTIFIED ORANIC COMPOUNDS MAY BE FORMED.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT FEDERAL, STATE AND LOCAL ENVIRONMENTAL
REGULATORS FOR GUIDANCE REGARDING PROPER DISPOSAL. IF PH IS 12.5 OR
GREATER, THE MATERIAL IS DEFINED AS A HAZARDOUS WASTE WITH EPA
WASTE NUMBER: D002.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:106 3130 FLEXICOLOR BLCH II REPL, PT B
Kit Part:Y
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 65-70%
Ingred Name:AMMONIUM BROMIDE
CAS:12124-97-9
RTECS #:BO9170000
Fraction by Wt: 1-5%
Ingred Name:AMMONIUM FERRIC ETHYLENEDIAMINETETRAACETIC ACID
CAS:21265-50-9
Fraction by Wt: 15-20%
Ingred Name:AMMONIUM FERRIC PROPYLENEDIAMINETETRAACETIC ACID
CAS:111687-36-6
Fraction by Wt: 5-10%
Ingred Name:1,3-PROPYLENEDIAMINETETRAACETIC ACID
CAS:1939-36-2
Fraction by Wt: 1-5%
Ingred Name:NITRIC ACID (SARA III)
CAS:7697-37-2
RTECS #:QU5775000
Fraction by Wt: 4%
Other REC Limits:NONE SPECIFIED
OSHA PEL:2 PPM/4 STEL
ACGIH TLV:2 PPM/4 STEL; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:LOW HAZARD FOR RECOMMENDED HANDLING.
Effects of Overexposure:EYES: IRRITATION. SKIN/INHALATION:LOW HAZARD
FOR RECOMMENDED HANDLING.
Medical Cond Aggravated by Exposure:NONE REPORTED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER & GET MEDICAL
ATTENTION IF ANY SYMPTOMS ARE PRESENT AFTER WASHING.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:USE AGENT APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING TO PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH MATERIAL TO SEWER WITH LARGE AMOUNTS OF
WATER.
Neutralizing Agent:SODIUM BICARBONATE
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED AND AWAY
FROM STRONG ALKALI.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED.
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT (MECHANICAL)
Other Protective Equipment:NONE SPECIFIED BY MFR.
Work Hygienic Practices:USE GOOD CHEMICAL HYGIENE PRACTICES.
Supplemental Safety and Health
THIS IS PART-B OF A TWO-PART KIT. THIS PART B HAS A KODAK SOLUTION NO:
5459. THIS CAT #106 3130 HAS REPLACED CAT #123 7759, WHICH HAS BEEN
DISCONTINUED. CAT#123-7759 ARE SHOWN AS P/N IND: A & B UNDER THIS
NSN. KEY1:C1
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:212F, 100C
Vapor Pres:18 MM
Vapor Density:0.6
Spec Gravity:1.177
pH:2.5
Solubility in Water:COMPLETE
Appearance and Odor:DARK BROWN LIQUID. SLIGHT ODOR.
Percent Volatiles by Volume:69
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALI
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE,CARBON MONOXIDE, OXIDES
OF NITROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W FEDERAL,STATE,LOCAL REGULATIONS.
MFR SUGGESTS FLUSH TO DRAIN.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:1294-1 (MK 77) MARTIN BAKER UNDERSEAT ROCKET MOTOR
Preparer's Name:T. GREEN
CAGE:51998
CAGE:51998
============= Composition/Information on Ingredients =============
Ingred Name:WET NITROCELLULOSE, NITROCELLULOSE, NITRATE CELLULOSE
CAS:9004-70-0
RTECS #:QW0975200
Fraction by Wt: 60%
Ingred Name:NITROGLYCERINE, NITRIN, NITROL
CAS:55-63-0
RTECS #:QX2100000
Fraction by Wt: 30%
Other REC Limits:0.05 PPM
OSHA PEL:S,C, 0.2 MG/M3 STEL
ACGIH TLV:S, 0.46 MG/M3; 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: HEADACHE, VOMITING,
NAUSEA, REDUCED BLOOD PRESSURE, RESPIRATORY IRRITATION, CHEST
PAINS, DIZZINESS, WEAKNESS, & RAPID PULSE. SKIN: DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: HEADACHE, VOMITING, NAUSEA, REDUCE
BLOOD PRESSURE, RESPIRATORY IRRITATION, CHEST PAINS, & RAPID PULSE.
SKIN: DERMATITIS.
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:DON'T FIGHT FIRE. IF IGNITION OCCURS, EVACUATE
THE AREA UNTIL THE UNIT HAS BURNED OUT.
Unusual Fire/Explosion Hazard:CLASSIFIED AS A DOT CLASS B EXPLOSIVE.
================== Accidental Release Measures ==================
Spill Release Procedures:AN UNDAMAGED UNIT MAY BE PICKED UP & RETURNED
TO ORIGINAL CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T EXPOSE TO ELECTRICAL DISCHARGE
OF ANY SORT. DON'T DROP OR ROUGH HANDLE IN ANY WAY. AVOID
APPLICATION OF PNEUMATIC PRESSURE TO ANY PORTS.
Other Precautions:AVOID INHALATION OF PRODUCTS OF COMBUSTION. ALCOHOL
MAY ENHANCE HEALTH EFFECTS. HANDLE AS HAZARD CLASS 1.3, STORAGE
COMPATABILITY GROUP C EXPLOSIVE IAW DOD 4145.26M.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE FOR ORDINARY HANDLING. EXPOSURE TO
PROPELLANT VAPORS REQUIRES RESPIRATOR PROTECTION.
Ventilation:LOCAL EXHAUST: RECOMMENDED.
Other Protective Equipment:FLAME RESISTANT CLOTHING
Supplemental Safety and Health
NET EXPLOSIVE WEIGHT: 6.8 LBS.
================== Physical/Chemical Properties ==================
Appearance and Odor:METAL PART. PROPELLANT GRAIN IS CYLINDERICAL SHAPE
OF BROWN COLOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:APPLICATION OF PRESSURE TO INLET PORT
==================== Disposal Considerations ====================
Waste Disposal Methods:IF UNIT IS DAMAGED OR NEEDS TO BE DISPOSED OF
FOR ANY REASON, IT SHOULD BE DISPOSED OF BY PERSONNEL QUALIFIED TO
DISPOSE OF EXPLOSIVES, AT AN APPROVED DISPOSAL SITE UNDER APPROVED
PROCEDURES REGULATED BY LOCAL, STATE, & FEDERAL LAWS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:VALCOOL TURN TECH, BLUE
CAGE:IO973
CAGE:29125
CAGE:IO973
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED (SEVERE)
HEAVY NAPHTHENIC; (MINERAL OIL)
CAS:64742-52-5
RTECS #:PY8035001
Fraction by Wt: 20%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHANOL, 2,2',2"-NITRILOTRI-; (TRIETHANOLAMINE)
CAS:102-71-6
RTECS #:KL9275000
Fraction by Wt: 10%
OSHA PEL:N/K
ACGIH TLV:5 MG/M3
Ingred Name:ETHANOL, 2-AMINO-; (ETHANOLAMINE)
CAS:141-43-5
RTECS #:KJ5775000
Fraction by Wt: 10%
OSHA PEL:3 PPM
ACGIH TLV:3 PPM/6 STEL
Ingred Name:ALKYLSULFAMIDOCARBOXYLATES; (ALKYLSULFAMIDO CARBOXYLATE
SALTS) (OR INGREDIENT 5)
CAS:72828-38-7
Fraction by Wt: 10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ALKYLSULFAMIDOCARBOXYLATES; (ALKYLFULFAMIDO CARBOXYLATE
SALTS)
CAS:72906-05-9
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:GLYCOL ETHER; (GLYCOL ETHERS)
CAS:1559-35-9
RTECS #:KK9625000
Fraction by Wt: 1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:WITH CONCENTRATED PRODUCT. SKIN IRRITATION CAN
RESULT FROM IMPROPER USE AND HANDLING OF CONCENTRATE OR MIX.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:OR MILK. IMMED CONT MD & OBTAIN MED
TREATMENT. SWALLOWING SM QTYS OF DILUTED PROD IS NOT EXPECTED (ING
9)
RTECS #:9999999ZZ
Ingred Name:ING 8:TO CAUSE INJURY/ILLNESS; BUT AS SHOULD BE EXPECTED
WHEN DRINKING OILY, SOAPY WATER, NAUS, DIARR/ABDOM (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:DISTRESS MAY BE EXPER. INHAL:NOT EXPECTED TO BE
PROBABLE ROUTE OF EXPOS TO PROD CONC. REMOVE TO FRESH AIR.(ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:SUPPORT BRTHG (GIVE O*2/ARTF RESP) . INHAL OF
DILUTED MIX CAN OCCUR IN APPLICATNS WHERE HIGH MIST (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:LEVELS ARE GENERATED. OSHA HAS A SET PEL OF 15 MG/M3
FOR ANY AIRBORNE PARTICULATE AS A NUISANCE LEVEL OF EXPOS.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH:DEFINED UNDER 49 CFR 261. MFR TECHNICAL
SERVICES (313-589-1000) CAN PROVIDE LIST OF WASTE (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:HAULERS FOR YOUR AREA. "EMPTY" CNTNRS WILL CNTN
RESIDUE WHICH IS NOT CONSIDERED HAZ WASTE UNDER RCRA (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:REGS. DRUMS CAN BE DRAINED TO A "DRIP DRY" CONDITION
BY INVERSION AND CAN BE OFFERED FOR RECYCLING OR SCRAP.
RTECS #:9999999ZZ
Ingred Name:VENT:CLOSE TOGETHER/VENT IS INADEQ, OPERATORS MAY EXPER
RESP IRRIT. FOR SUCH APPLICATNS, USE OF SPLASH GUARDS (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:OR MIST COLLECTORS IS RECOMMENDED.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROD CONC:INHAL:N/A. EYE:PRIMARY
IRRIT. SKIN:MAY BE PRIMARY IRRIT. INGEST:NOT ORALLY TOX. PROD @ USE
DILUTION:INHAL:EXTENDED TO MISTS MAY CAUSE UPPER RESP IRRIT.
EYE:WILL CAUSE STINGING SENSATION. SKI N:NOT IRRIT WHEN USED AS
DIRECTED & GOOD PERS HYGIENE IS PRACTICED. INGEST:SM QTYS MAY CAUSE
NAUS OR (FTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:DIARR. WHEN USED IN APPLICATNS
GENERATING HIGH LEVELS OF MIST, OPERATOR EXPOS CAN BE MIN BY PROPER
VENT, USE OF MIST COLLECTORS/SPLASH GUARDS, AS APPROP. IF THERE IS
DOUBT ABOUT ACTUAL MIST LEVELS PRESENT, MONITORING SHOULD BE
CONDUCTED. MILD SKIN IRRIT (REDNESS & DRYNESS OF HANDS) MAY BE
EXPER WHEN (SUPDAT)
Medical Cond Aggravated by Exposure:MAY AGGRAVATE EXISTING SKIN
IRRITATION WHERE FURTHER DEFATTING OR SKIN PENETRATION COULD OCCUR.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH IMMED W/RUNNING WATER FOR @ LST 15 MIN, THEN
PROMPTLY GET MED ATTN TO CHECK FOR POSS IRRIT. SKIN:CONC:WASH
W/WATER AS SOON AS POSS. DILUTED PROD IS NOT IRRIT WHEN USED AS REC
& GOOD PERS HY GIENE IS PRAC. REMOVE SEV CONTAM CLTHG,INCLUDING
SHOES. LAUNDER BEFORE REUSE. IF IRRIT PERSISTS, GET MED ATTN.
INGEST:IF CONC/MIX IS SWALLOWED, DO NOT INDUCE VOMIT. DILUTE BY
DRINKING WATER (ING 8)
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE . NOT
APPLICABLE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . NONE.
Unusual Fire/Explosion Hazard:NONE. HAZARDOUS COMBUSTION
PRODUCTS:SMOKE, FUMES AND OXIDES OF CARBON.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN THE SPILL, COLLECT ON ABSORBENT
MATERIAL AND DISCARD AS DICTATED BY FEDERAL, STATE AND LOCAL
REGULATIONS THAT MAY APPLY. FLUSH AREA THOROUGHLY WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE ONLY AS RECOMMENDED BY MFR. AVOID
ALL CONTACT OF CONCENTRATE WITH EYES OR SKIN. DO NOT SWALLOW. IF
FROZEN, THAW COMPLETELY AT ROOM TEMPERATURE.
Other Precautions:CONTAINS AMINES. DO NOT ADD SODIUM/OTHER NITROSATING
AGENTS TO PROD. SUSPECTED CANCER-CAUSING NITROSAMINES COULD BE
FORMED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . PRODUCT IS NOT VOLATILE.
Ventilation:FOR MOST APPLICATNS, NORMAL SHOP VENT IS ADEQ. HOWEVER,
WHEN HIGH MIST LEVELS ARE GENERATED/WHERE MACHINES ARE (ING 16)
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER . EFFECTIVE METALWORKING PLANT PROT CLTHG AS APROP.
Work Hygienic Practices:GOOD PERSONAL HYGIENE SHOULD ALWAYS BE
FOLLOWED.
Supplemental Safety and Health
PH (CONC):9.1; (5% MIX):8.9. EFTS OF OVEREXP:DILUTED PROD HAS BEEN
CONTAM BY CERTAIN OILS, BY DISSOLVED METALS/WHEN MIX RATIO IS TOO
STRONG. WHEN PROBLEMS OCCUR, USE OF WATER-RESIST BARRIER CREAMS MAY
BE TEMPORARY CTL MEASURE. CONT MFR (810-589-1000) FOR SPECIFIC
RECS. SIGNS & SYMPS:EYE INJURY MAY RSLT FROM CONT(ING 7)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:LIKE WATER
Spec Gravity:1.031
pH:SUPDAT
Evaporation Rate & Reference:LIKE WATER
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR; PLEASANT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID ADDITION OF STRONG ACIDS TO PRODUCT CONCENTRATE.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:SMOKE, FUMES, OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:USED MIX:DISP PROC MUST COMPLY W/LOC, COUNTY,
STATE & FED REGS. IF PRE-TREATMENT IS NEEDED, CHEM EMULSION
BREAKING/ULTRAFILTRATION MAY BE USED. CONT MFR TECHNICAL SERVICES
(313-589-1000) FOR ASSISTANC E. UNUSED CONC:CONC IS NOT HAZ WASTE
AS(ING 13)
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:M-COAT B (B.F. GOODRICH ADHES SYS A-178-B)
CAGE:88952
CAGE:88952
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 80%
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:NITRILE RUBBER
Fraction by Wt: 20%
===================== Hazards Identification =====================
Effects of Overexposure:NAUSEA/DIZZINESS/LOSS OF COORDINATION/IRRITANT
TO MUCOUS MEMBRANES. SKIN: DEFATTING/DERMATITIS.
======================= First Aid Measures =======================
First Aid:INGESTION: REMOVE TO FRESH AIR. SKIN CONTACT: WASH AFFECTED
AREA WITH SOAP AND WATER. EYE CONTACT: FLUSH WITH COPIOUS AMOUNTS
OF WATER FOR AT LEAST 5 MINUTES. INGESTION: DON'T INDUCE VOMITING.
SEEK ME DICAL AID.
===================== Fire Fighting Measures =====================
Flash Point:20F (TCC)
Lower Limits:2%
Upper Limits:7.0%
Extinguishing Media:WATER FOG, CO2, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:DON'T ENTER CONFINED FIRE SPACE W/OUT NIOSH
APPROVED SCBA
Unusual Fire/Explosion Hazard:VAPORS >AIR/MAY TRAVEL/BUILD-UP IN POORLY
VENTILATED AREAS CAUSING FLASH FIRES/EXPLOSION/FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES-VENTILATE AREA.
AVOID BREATHING VAPORS, SKIN AND EYE NTACT. WIPE UP WITH ABSORBENT
MATERIALS AND PLACE IN SUITABLE CLOSED CONINER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE 80F (27C) IN DRY, WELL
VENTILATED AREA FREE OF IGNITION SOURCES. KEEP CONTAINERS
TIGHTLYEALED.
Other Precautions:AVOID PROLONGED BREATHING OF VAPORS AND SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:>TLV, USED NIOSH APPROVED RESPIRATOR FOR
ORGANICVAPORS.
Ventilation:PROVIDE LOCAL EXHAUST VENTILATION TO KEEP BELOW TLV.
Supplemental Safety and Health
MSDS DATE: 10 JUN 1986.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:175F
Vapor Pres:71
Vapor Density:3.8
Spec Gravity:0.84
Evaporation Rate & Reference:(BU AC = 1) 1.9
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TAN VISCOUS LIQUID WITH KETONE ODOR
Percent Volatiles by Volume:85%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:OXIDES OF CARBON, SMOKE, ALIPHATICS
AND OTHERS.
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS MATERIAL IF DISCARDED IS HAZARDOUS AND MUST
BE DISPOSED OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:KBX23P506Q
CAGE:14655
CAGE:14655
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR.AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UNC ONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CARBONIC ACID, LEAD (II) SALT, 7381
CAGE:DO242
CAGE:63612
CAGE:DO242
============= Composition/Information on Ingredients =============
Ingred Name:LEAD CARBONATE; (CARBONIC ACID, LEAD (II) SALT)
CAS:598-63-0
RTECS #:OF9275000
OSHA PEL:0.05 MG/M3 (PB)(MFR)
ACGIH TLV:0.15 MG/M3 (PB)(MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL BY INGESTION AND INHALATION.
CUMULATIVE POISON. CAUSES ABDOMINAL PAIN, DIARRHEA, NAUSEA,
INSOMNIA, WEAKNESS, JOINT AND MUSCLE PAIN, HEADACHE, DIZZINESS,
PALLOR, ANEMIA. TESTS ON LABORATORY ANI MALS INDICATE MATERIAL MAY
PRODUCE ADVERSE REPRODUCTIVE EFFECTS. NOTE:LEAD APPEARS ON THE NAVY
LISTING (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:OF OCCUPATIONAL CHEMICAL REPRODUCTIVE
HAZARDS. SEEK CONSULTATION FROM APPROPRIATE HEALTH PROFESSIONALS
CONCERNING LATEST HAZARD LIST INFORMATION AND SAFE HANDLING AND
EXPOSURE INFORMATION (FP N).
Medical Cond Aggravated by Exposure:DATA NOT AVAILABLE.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ASSISTANCE FOR ALL CASES OF OVEREXPOSURE.
SKIN:WASH THOROUGHLY W/SOAP & WATER. EYES:IMMEDIATELY FLUSH
THOROUGHLY W/WATER FOR AT LEAST 15 MINUTES. INHAL:REMOVE TO FRESH
AIR; GIVE ARTIFICIAL RESPIRATION IF BREATHING HAS STOPPED.
INGEST:IF CONSCIOUS, DRINK WATER & INDUCE VOMITING IMMEDIATELY AS
DIRECTED BY MEDICAL PERSONNEL. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONCOMBUSTIBLE
Extinguishing Media:USE ANY SUITABLE FOR SURROUNDING MATERIALS.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCES TOXIC
FUMES. IGNITES SPONTANEOUSLY & BURNS FIERCELY IN FLUORINE.
================== Accidental Release Measures ==================
Spill Release Procedures:TAKE UP & CONTAINERIZE FOR PROPER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. STORE IN A
COOL, WELL-VENTILATED AREA. DO NOT BREATHE DUST. DO NOT GET IN
EYES, ON SKIN OR ON CLOTHING.
Other Precautions:DO NOT TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF WORKPLACE EXPOS LIM(S) OF PROD/ANY COMPONENT
IS EXCEEDED, A NIOSH/MSHA APPRVD AIR SUPPLIED RESP IS ADVISED IN
ABSENCE OF PROPER ENVIRON CONTROL. OSHA REGS ALSO PERMIT OTHER
NIOSH/MSHA APPRVD RESPS (NEG PRESS TYPE) UNDER SPECIFIED(SUPDAT)
Ventilation:MATERIAL MUST BE HANDLED OR TRANSFERRED IN AN APPROVED FUME
HOOD OR W/EQUIVALENT VENTILATION.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . SAFETY EQUIPMENT SHOULD BE READILY
AVAILABLE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
RESP PROT:CONDITIONS (SEE YOUR SAFETY EQUIPMENT SUPPLIER). ENGINEERING
&/OR ADMINISTRATIVE CONTROLS SHOULD BE IMPLEMENTED TO REDUCE
EXPOSURE.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:752F,400C
Spec Gravity:6.61 (H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:HEAVY WHITE POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS.
Stability Condition to Avoid:EXTREME HEAT.
Hazardous Decomposition Products:PB FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:TO BE PERFORMED IN COMPLIANCE W/ALL CURRENT
LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
NIIN: 01-045-3517
Product ID: DETERGENT LAUNDRY
Cage: OFTT5
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: OFTT5
Assigned Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: OFTT5
Cage: 1A864
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: DETERGENT,LAUNDRY
Specification Number: CID-A-A-50153
Unit of Issue: DR
Quantitative Expression: 00000000055GL
UI Container Qty: 0
Type of Container: METAL
=======================================================
Ingredients
=======================================================
Cas: 68439-46-3
% Wt: 30
Other REC Limits: NONE SPECIFIED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Signs And Symptions Of Overexposure: MAY CAUSE EYE IRRITATION, POSSIBLE CORNEAL
DAMAGE. PROLONGED CONTACT WITH SKIN MAY CAUSE DEFATTING AND IRRITATION OF
SKIN.
Medical Cond Aggravated By Exposure: OPEN CUTS AND SORES.
First Aid: FOR CONTACT WITH SKIN OR CLOTHES, WASH WITH SOAP AND WATER. FOR
CONTACT WITH EYES, FLUSH WITH WATER FOR 15 MUNUTES AND CONSULT A
PHYSICIAN/OPHTHALMOLOGIST IF IRRITATION PERSISTS. IF SWALLOWED, GIVE LA RGE
AMOUNTS OF WATER OR MILK AND GET IMMEDIATE MEDICAL AID.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: PICK UP SPILLAGE WITH ABSORBENT MATERIAL. FLUSH AREA
WITH WATER. FLOORS MAY BE SLIPPERY. TAKE CAUTION TO AVOID FALLS.
Waste Disposal Methods: DISPOSE OF OF IN ACCORDANCE WITH APPLICABLE LOCAL,
STATE AND FEDERAL REGULATIONS.
Handling And Storage Precautions: KEEP OUT OF REACH OF CHILDREN. STORE IN DRY
COOL PLACE.
Other Precautions: DO NOT INGEST.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM IF PRODUCT IS INVOLVED
IN FIRE.
Fire Fighting Procedures: KEEP FIRE EXPOSED CONTAINERS COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard: PRODUCT WILL NOT BURN BUT MAY SPLATTER IF
EXPOSED TO HIGH TEMPERATURES.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE NEEDED WITH NORMAL ROOM VENTILATION.
Other Protective Equipment: EYEWASH STATIONS
Work Hygienic Practices: WASH HANDS AFTER HANDLING.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 212F,100C
Vapor Pres: .62
Spec Gravity: 1.017
PH: 9.15
Evaporation Rate & Reference: 1 (WATER=1)
Solubility in Water: COMPLETE
Appearance and Odor: CLEAR BLUE LIQUID; DETERGENT ODOR.
Percent Volatiles by Volume: 65
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Hazardous Decomposition Products: NORMAL COMBUSTION PRODUCTS FROM BURNING.
CARBON DIOXIDE AND CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 102474
Product ID: DETERGENT LAUNDRY
Review Date: 08/18/1992
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: DR
Container QTY: 0
Type Of Container: METAL
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: DETERGENT LAUNDRY
Cage: OFTT5
Assigned IND: Y
Company Name: LHB INDUSTRIES
Street: 8833 FLEISCHER PLACE
Zipcode: 63134
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: N/K
MAY CAUSE EYE IRRITATION, POSSIBLE CORNEAL DAMAGE.
PROLONGED CONTACT WITH SKIN MAY CAUSE DEFATTING AND IRRITATION OF SKIN.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TKO REFRIGERATION OIL ACID TEST KIT
CAGE:HO994
CAGE:8J132
CAGE:HO994
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA 313) (CERCLA)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 40-60%
OSHA PEL:200 PPM
ACGIH TLV:50 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL ALCOHOL
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 45-55%
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL OF VAPS MAY BE NARC OR
ANESTH. IRRIT OF RESP TRACT, NERVOUS SYS DEPRESS, HDCH, DIZZ, STAG
GAIT, CONFUSN, UNCON, COMA. INGEST OF LIQ WILL CAUSE GI DISTRESS,
IRRIT & POSS NAUS. LIQ/VAPS MAY BE IRRIT TO SKIN & EYES. SKIN
IRRIT DEVELOPS SLOWLY AFTER CNTCT. EYE IRRIT DEVELOPS IMMED UPON
CNTCT. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: CHRONIC: TOLUENE APPEARS ON THE NAVY
LIST OF OCCUP CHEM REPRO HAZS. SEEK CONSULTATION FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG & EXPOS
INFO . KIDNEY & LIVER DMG & BLOOD EFTS. ETHANOL IS ANIARC CARCIN
IN THE FORM OF DRINKING BEVERAGES ONLY.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH EYES W/WATER FOR AT LEAST 15 MIN. GET MED ATTN IF
SYMPS DEVELOP & PERSIST. SKIN:FLUSH W/WATER OR SOAP & WATER FOR 15
MIN OR UNTIL ALL TRACES HAVE BEEN REMOVED. SEEK MED ATTN IF SYPS
DEVELOP & PERSIST. INGEST:DO NOT INDUCE VOMIT.RINSE MOUTH OUT
W/WATER. GET IMMED MED ATTN. INHAL:REMOVE TO FRESH AIR & IF NEEDED,
IMMED BEGIN ARTF RESP. GIVE OXYGEN IF BRTHG IS LABORED. GET EMER
(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:39.9F,4.4C
Lower Limits:1.4%
Upper Limits:7.0%
Extinguishing Media:DRY POWDER, CARBON DIOXIDE, WATER FOG OR SPRAY.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . APPROACH FIRE FROM UPWIND SIDE. AVOID BRTHG
SMOKE, FUMES, MIST OR VAPORS ON DOWNWIND SIDE.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:EMER RESPONSE COORDINATOR MUST HAVE MANDATED
TRAINING. ELIM ALL IGNIT SOURCES. SM SPILLS: PICK UP W/ABSORB MATLS
& PLACE IN NON-LEAKING CNTNRS; SEAL TIGHTLY FOR PROPER DISP OR
REUSE. LG SPILLS: EVACUA TE HAZ AREA OF UNPROTECTED PERS. WEAR
(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN ACOOL PLACE AWAY FROM
IGNITION SOURCES. STORE AWAY FROM OXIDIZERS.
Other Precautions:CLEAN UP LEAKS AND SPILLS IMMEDIATELY TO PREVENT SOIL
OR WATER CONTAMINATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:LOCAL EXHAUST AND MECHANICAL VENTILATION RECOMMENDED.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
BOOTS, APRONS AS NEEDED FOR PROTECTION AGAINST SPILLS &/OR
SPLASHES.
Work Hygienic Practices:AVOID CNTCT W/SKIN, EYES & CLTHG. AFTER HNDLG
THIS PROD, WASH HANDS BEFORE EATING, DRINKING OR SMKNG. IF CNTCT
(SUPDAT)
Supplemental Safety and Health
FIRST AID PROC: MED HELP. CONTACT MD IMMED. SPILL PROC: APPROP
NIOSH/MSHA APPRVD RESP & PROT CLTHG. SHUT OFF SOURCE OF LEAK IS
SAFE TO DO SO. DIKE & CNTN. REMOVE W/VACUUM TRUCKS/PUMP TO STORAGE
VESSEL S. HYGIENE PRACT: OCCURS, REMOVE CONTAMD CLTHG. IF NEEDED,
TAKE FIRST AID ACTION. LAUNDER CONTAMD CLTHG BEFORE REUSE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:172F,78C
Vapor Pres:19
Vapor Density:1.6
Spec Gravity:0.86 (H*2O=1)
VOC Pounds/Gallon:860
Evaporation Rate & Reference:<1 (BUAC=1)
Solubility in Water:PARTIALLY
Appearance and Odor:CLEAR LIQUID; SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACTIVE METALS, OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:FROM COMBUSTION: SMOKE, CARBON
MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS .
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ALUMINUM ELECTRODE,UNIVERSAL,ALL POSITION.
CAGE:05575
CAGE:05573
CAGE:05575
============= Composition/Information on Ingredients =============
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: 1-6%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:FLUORIDE ION (1-)
CAS:16984-48-8
RTECS #:LM6290000
Fraction by Wt: 16%
OSHA PEL:2.5 MG/M3 (F)
ACGIH TLV:2.5 MG/M3 (F); 8990
Ingred Name:CHLORIDES
Fraction by Wt: 25%
ACGIH TLV:10 MG/CUM (MFR)
Ingred Name:ALUMINUM (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: BAL
OSHA PEL:15MG/M3 DUST/5 FUME
ACGIH TLV:10MG/M3 DUST; 9192
===================== Hazards Identification =====================
Effects of Overexposure:FUMES: DIZZINESS
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Extinguishing Media:SUFFICIENT FOR SURROUNDING FIRE
================== Accidental Release Measures ==================
Spill Release Procedures:NORMAL CLEANLINESS
======================Handling and Storage ======================
Handling and Storage Precautions:REFER TO AWS PUBLICATION: ANSI
Z49.1-1973
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:NORMAL FOR WELDING.
Supplemental Safety and Health
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY WITH LOCAL,STATE AND FEDERAL REGULATIONS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:10-636, JIFF ACTION CONTACT CLEANER
CAGE:EO032
CAGE:EO032
CAGE:72653
============= Composition/Information on Ingredients =============
Ingred Name:TRICHLOROFLUOROMETHANE (CFC-11) (SARA III)
CAS:75-69-4
RTECS #:PB6125000
Fraction by Wt: 48%
OSHA PEL:1000 PPM
ACGIH TLV:C, 1000 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ozone Depleting Chemical:1
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 24%
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 14%
OSHA PEL:350 PPM/450 STEL
ACGIH TLV:350 PPM/450STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:LIGHT OIL
Fraction by Wt: 10%
Ingred Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: 4%
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM/30000STEL;93
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Effects of
Overexposure:HEADACHE,DIZZINESS,NAUSEA,LIGHTHEADEDNESS,SHORTNESS OF
BREATH,CONFUSION,MENTAL
DEPRESSION,NARCOSIS,DROWSINESS,ANESTHESIA,UNCONSCIOUSNESS.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH WITH WATER FOR 15 MIN; SKIN:WASH WITH SOAP & WATER;
INH:REMOVE TO FRESH AIR,USE ARTIFICIAL RESPIRATION IF NECESSARY;
ING:GASTRIC LAVAGE-DO NOT INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point:AEROSOL
Extinguishing Media:CO*2,FOAM
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:VENTILATE AREA.WELL-TOXIC GASES EMITTED
UPON DECOMPOSITION.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT MATERIAL TO COLLECT-STORE IN
SEALED METAL DRUMS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT OR FLAME.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE SELF-CONTAINED BREATHING APPARATUS IF
EXCEEDS TLV.
Ventilation:GENERAL MECHANICAL.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V2
Spec Gravity:1.0
Evaporation Rate & Reference:SAME AS BUTYL ACETATE
Solubility in Water:SLIGHT
Appearance and Odor:CLEAR LIQUID,ALCOHOL ODOR
Percent Volatiles by Volume:90
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT,OPEN FLAMES
Hazardous Decomposition Products:HYDROCHLORIC ACID,HYDROFLUORIC
ACID,CARBONYL HALIDES,FLUORINE,CHLORINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:AUTHORIZED DISPOSAL FACILITY (INCINERATOR).
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:169 7341- EKTACOLOR RA 100 DEVELOPER REPLEN
Kit Part:Y
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 70-75%
Ingred Name:N-(2-(4-AMINO-N-ETHYL-M-TOLUIDINO)ETHYL)METHANESULFONAMIDE
SULFATE
CAS:25646-71-3
RTECS #:PB0431000
Fraction by Wt: 15-20%
Ingred Name:LITHIUM SULFATE
CAS:10377-48-7
RTECS #:OJ6419000
Fraction by Wt: 5-10%
Ingred Name:POTASSIUM SULFITE
CAS:10117-38-1
RTECS #:WT3530000
Fraction by Wt: 1-5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: VAPOR IRRITATING. SULFUR
DIOXIDE GAS IN LOW CONCENTRATIONS CAN CAUSE UPPER RESPIRATORY TRACT
IRRITATION. SKIN: IRRITATION & ALLERGIC SKIN REACTION. INGESTION:
HARMFUL. EYES: VAPOR & LIQUID MAY CAUSE IRRITATION.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR, TREAT SYMPTOMS. EYES:
IMMEDIATELY FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN. SKIN:
FLUSH W/PLENTY OF WATER & WASH W/NONALKALINE (ACID) TYPE OF SKIN
CLEANER; IF ALLER GIC REACTION DEVELOPS GET MEDICAL ATTENTION.
INGESTION: INDUCE VOMITING IMMEDIATELY. NEVER GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS PERSON. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CO2, ALCOHOL FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:NEUTRALIZE W/BAKING SODA. FLUSH TO SEWER
W/LARGE AMOUNTS OF WATER.
Neutralizing Agent:SODIUM BICARBONATE (BAKING SODA)
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM CONTACT W/OXIDIZING
MATERIALS. KEEP CONTAINER TIGHTLY CLOSED & AWAY FROM BASES.
Other Precautions:THIS CHEMICAL FORMULATION MAY CAUSE ADVERSE
ENVIRONMENTAL EFFECTS IF DISCHARGED DIRECTLY W/OUT TREATMENT. AFTER
DILUTION & SECONDARY WASTE TREATMENT THIS FORMULATION IS NOT
EXPECTED TO HAVE ANY ADVERS E ENVIRONMENTAL IMPACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH APPROVED ACID GAS RESPIRATOR SHOULD BE
WORN IF NEEDED.
Ventilation:GENERAL/LOCAL EXHAUST/ENCLOSED HANDLING SYSTEM: TO MAINTAIN
LEVELS BELOW TLV. TYPICALLY 10 ROOM VOLUMES PER HOUR.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING & SH0ES. WASH
CLOTHING BEFORE REUSE. DESTROY OR THOROUGHLY CLEAN CONTAMINATED
SHOES.
Supplemental Safety and Health
ROUTINE USE OF NONALKALINE (ACID) TYPE OF SKIN CLEANER & REGULAR
ALLERGIC SKIN REACTION. THIS CHEMICAL HAS POTENTIAL TO AFFECT AQUAT
IC & SECONDARY WASTE TREATMENT ORGANISMS, AFFECT GERMINATION &
GROWTH OF SOME PLANTS, BUT IS BIODEGRADABLE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>100C/212F
Vapor Pres: 18
Vapor Density:0.6
Spec Gravity:1.12
pH:<1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR YELLOW TO BROWN SOLUTION; SHARP SULFUR
DIOXIDE ODOR.
Percent Volatiles by Volume: 74/WT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, STRONG BASES
Stability Condition to Avoid:HEAT, FIRE, & OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:CO2, CO, OXIDES OF NITROGEN & SULFUR
(SULFUR DIOXIDE)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE, OR LOCAL LAW.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:711175 QUANTAB CHLORIDE TITRATOR
CAGE:1BY35
CAGE:1BY35
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM BICHROMATE (SARA III)
CAS:7778-50-9
RTECS #:HX7680000
Other REC Limits:NONE SPECIFIED BY M.
OSHA PEL:C,0.1 MG/M3 CRO3
ACGIH TLV:0.5 MG CR/M3; 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS 190MG/KG K*2CR*2O*7
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:PRODUCT CONTAINS A LOW LEVEL OF
CARCINOGENIC HEXAVALENT CHROMIUM (LESS THAN 0.01% BY WEIGHT IN AN
INDIVIDUAL TITRATOR) AND, THEREFORE, IS CONSIDERED TO BE
NON-HAZARDOUS. ABSORPTION THROUGH SKIN CAN CA USE SYSTEMIC
POISONING & ECZEMATIC DERMATITIS. EXPOSURE UNLIKELY SINCE CHEMICAL
IS SEALED IN A LAMINATED SHEATH.
Explanation of Carcinogenicity:CHROMIUM (VI) IS LISTED AS A HUMAN
CARCINOGEN.
Effects of Overexposure:IRRITATION, NAUSEA AND VOMITING.
Medical Cond Aggravated by Exposure:MAY AGGRAVATE PRE-EXISTING SKIN
DISORDERS.
======================= First Aid Measures =======================
First Aid:SKIN:WASH AFFECTED PARTS THOROUGHLY. INGEST:CONSULT
PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:FLOOD WITH LARGE AMOUNTS OF WATER.DO NOT ALLOW
WATER TO ENTER SEWER.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:MANUFACTURER STATES NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP;REUSE OR DISPOSE OF.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP MATERIAL DRY.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NEEDED IN NORMAL SERVICE.
Ventilation:USE GENERAL DILUTION VENTILATION.
Other Protective Equipment:NONE
Work Hygienic Practices:DO NOT DISASSEMBLE DEVICE OR EXPOSE CHEMICAL
STRIP.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:932F,500C
Solubility in Water:NEGLIGIBLE
Appearance and Odor:ORANGE-RED PAPER STRIP LAMINATED WITHIN A PLASTIC
SHEATH, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REDUCING AGENTS AND COMBUSTIBLES.
Stability Condition to Avoid:HIGH HEAT,SOURCES OF IGNITION.
Hazardous Decomposition Products:TOXIC CHROMIUM TRIOXIDE FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AS RCRA WASTE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:863 0683 COM PROFESSIONAL DEVELOPER AND REPLENISHER, W.S.
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 85-90%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM SULFITE
CAS:10117-38-1
RTECS #:WT3530000
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:HYDROQUINONE (SARA 302/313) (CERCLA)
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9596
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:DIETHYLENE GLYCOL
CAS:111-46-6
RTECS #:ID5950000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM CHLORIDE
CAS:7447-40-7
RTECS #:TS8050000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): NOT GIVEN
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. MAY LIBERATE SULFUR DIOXIDE GAS WHICH IS
IRRITATING TO RESPIRATORY TRACT. EYE CONTACT CAUSES IRRITATION. MAY
CAUSE ALLERGIC SKIN REACTI ON. PROLONGED/REPEATED SKIN CONTACT
MAYCAUSE IRRITATION. HARMFUL IF SWALLOWED. CAN CAUSE KIDNEY DAMAGE
AND CNS EFFECTS.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:KIDNEY DAMAGE, CNS EFFECTS, DIFFICULT
BREATHING, EYE IRRITATION, ALLERGIC SKIN REACTION, SKIN IRRITATION,
WHEEZING, CHEST TIGHTNESS, STOMACH UPSET, HIVES, FAINTNESS,
WEAKNESS, DIARRHEA.
Medical Cond Aggravated by Exposure:SOME ASTHMATICS OR
SULFITE-SENSITIVE INDIVIDUALS MAY EXPERIENCE WHEEZING, CHEST
TIGHTNESS, STOMACH UPSET, HIVES, FAINTNESS, WEAKNESS, DIARRHEA.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMMEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: ONLY INDUCE VOMITING AT INSTRUCTION OF MEDICAL
PERSONNEL. NEVER GIVE ANYTHING BY MOUTH IF UNCONSCIOUS. CALL
PHYSICIAN OR POISON CONTROL ASAP.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:NONFLAMMABLE. USE EXTINGUISHING MEDIA SUITABLE FOR
SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER IF ALLOWABLE WITH LARGE AMOUNTS
OF WATER. OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT
MATERIAL, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN
SURFACE TO REMOVE RESIDUA L CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING VAPOR/MIST. AVOID
CONTACT WITH EYES, SKIN AND CLOTHING. USE WITH ADEQUATE
VENTILATION. KEEP FROM CONTACT WITH OXIDIZING MATERIALS.
Other Precautions:KEEP CONTAINER CLOSED.THE ROUTINE USE OF A
NONALKALINE (ACID) TYPE OF HAND CLEANER AND REGULAR CLEANING OF
WORKING SURFACES WILL HELP MINIMIZE THE POSSIBILITY OF A SKIN
REACTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED. A RESPIRATOR SHOULD BE
WORN IF HAZARDOUS DECOMPOSITION PRODUCTS ARE LIKELY TO BE RELEASED
OR HAVE BEEN RELEASED. RESPIRATOR TYPE: ACID GAS.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:NOT GIVEN
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Decomp Temp:Decomp Text:NOT GIVEN
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.084
pH:10.9
Viscosity:NOT GIVEN
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:YELLOW LIQUID, NO ODOR
Percent Volatiles by Volume:85-90%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
SULFUR DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. MAY REQUIRE NEUTRALIZATION IF PH
< 2.0 OR PH > 12.5. DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE ANDLOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CYCLOPENTANE
CAGE:BAXTE
CAGE:BAXTE
CAGE:2H215
============= Composition/Information on Ingredients =============
Ingred Name:CYCLOPENTANE
CAS:287-92-3
RTECS #:GY2390000
Fraction by Wt: 100%
Other REC Limits:600 PPM
ACGIH TLV:600 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION TO RESPIRATORY
TRACT, POSSIBLE DEATH FROM RESPIRATORY FAILURE DUE TO EXTREMELY
HIGH VAPOR CONCENTRATIONS. EYES: IRRITATION. SKIN:
PROLONGED/REPEATED CONTACT CAN CAUSE IRRITATION & DERMATITIS.
INGESTION: CAN CAUSE GI TRACT DISCOMFORT. CNS DEPRESSION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DIZZINESS, HEADACHE,
INCOORDINATION, DEPRESSION, NARCOSIS, COMA, DEFATTING.
Medical Cond Aggravated by Exposure:PRECLUDE FROM EXPOSURE THOSE
INDIVIDUALS SUSCEPTIBLE TO DERMATITIS.
======================= First Aid Measures =======================
First Aid:INHALATION: IMMEDIATELY REMOVE TO FRESH AIR. GIVE MOUTH TO
MOUTH/CPR. EYES: RINSE W/COPIOUS AMOUNTS OF WATER FOR 15 MINS.
SKIN: FLUSH THOROUGHLY FOR 15 MINS. WASH W/SOAP & WATER. INGESTION:
ASPIRATION HAZARD-DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION
IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-34.6F
Lower Limits:1.1
Upper Limits:8.7
Extinguishing Media:CO2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WATER MAY SPREAD THE FIRE. A WATER SPRAY CAN
BE USED TO COOL A FIRE EXPOSED CONTAINER. WEAR FULL PROTECTIVE
CLOTHING & SCBA.
Unusual Fire/Explosion Hazard:VERY VOLATILE & EXTREMELY FLAMMABLE. HEAT
WILL BUILD PRESSURE & MAY RUPTURE CLOSED STORAGE CONTAINERS.
AUTOIGNITION TEMP. 681.8F.
================== Accidental Release Measures ==================
Spill Release Procedures:PROTECT FROM IGNITION. WEAR PROTECTIVE
CLOTHING & USE APPROVED RESPIRATOR EQUIPMENT. ABSORB MATERIAL IN AN
ABOSORBENT RECOMMENDED FOR SOLVENTS & REMOVE TO A SAFE LOCATION FOR
DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN AN ACCEPTABLY PROTECTED &
SECURE FLAMMABLE LIQUID STORAGE ROOM. AVOID OPEN CONTAINERS & POOR
VENTILATION.
Other Precautions:AVOID TEMP. EXTREMES & DIRECT SUNLIGHT. GROUND & BOND
METAL CONTAINERS TO MINIMIZE STATIC SPARKS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE APPROVED RESPIRATOR EQUIPMENT,
AIR-PURIFYING, AIR-SUPPLIED/SCBA.
Ventilation:ADEQUATE; LOCAL/GENERAL
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE. DISCARD CONTAMINATED SHOES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:120.74F
Melt/Freeze Pt:M.P/F.P Text:136.97F
Vapor Pres:400
Vapor Density:2.4
Spec Gravity:0.745
Evaporation Rate & Reference:(BU AC = 1): >10
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR COLORLESS LIQUID W/A STRONG HYDROCARBON ODOR
Percent Volatiles by Volume: 100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, DIRECT SUNLIGHT,
TEMP EXTREMES.
Hazardous Decomposition Products:CO, TOXIC VAPORS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. EPA HAZARDOUS WASTE #D001 (IGNITABLE), UN1146.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DRY CLEANING SOLVENT,P-D-680
Preparer's Name:DGSC-SSH
CAGE:85394
CAGE:85394
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 100%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS AND SYMPTOMS.
Effects of Overexposure:ANESTHESEA, HEADACHE, NAUSEA, DIZZINESS, ETC.
IRRITATING TO SKIN & EYES.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION- GET TO FRESH AIR. EYES- FLOOD W/ WATER;SEEK
MEDICAL ASSIST. SKIN- WASH W/ MILD SOAP & WATER. INGESTION- CALL
PHYSICIAN.REMOVE ALL CONTAMINATED CLOTHING & WASH BEFORE REUSE.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:113F,45C
Lower Limits:1.0
Upper Limits:6.0
Extinguishing Media:FOAM,CARBON DIOXIDE,DRY CHEM,WATER-FOG,STEAM
Fire Fighting Procedures:DO NOT USE WATER. EXCLUDE AIR. CONSULT LOCAL
FIRE MARSHALL.
Unusual Fire/Explosion Hazard:HANDLE AS A COMBUSTIBLE MATERIAL.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH W/WATER INTO RETAINING AREA O CONTAINER.
AVOID SPARKS, FIRE OR HOT METAL. SMALL QTY MAY BE ABSORBED ONTO
APPROPRIATE ABSORBENT.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL PLACE AWAY FRO SOURCES
OF IGNITION. USE ONLY W/ADEQUATE VENT. AVOID PROLONGED OR REPEATED
BREATH OF VAPORS & CONTACT.
Other Precautions:HANDLE AS A COMBUSTIBLE MATL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ABOVE TLV-USE CARTRIDGE RESPIRATOR OR GAS MASK.
Ventilation:LOCAL EXH OR MECHAN W/APPRVD CLASS D EXPLOS-PROOF
MOTOR,SWIT
Other Protective Equipment:APRON,SKIN BARRIER CREAM
Work Hygienic Practices:WASH HANDS AFTER USE.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:323F,162C
Vapor Pres:5
Vapor Density:4.8
Spec Gravity:0.786
Evaporation Rate & Reference:0.08 (N-BUT ACET=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT COLORED LIQUID W/CHARACTERISTIC HYDROCARBON
ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH IGNITION SOURCES, OPEN FLAME, SPARKS,
ETC.
Hazardous Decomposition Products:CARBON MONOXIDE & CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE UNDER SAFE CONDITIONS OR DISPOSE OF
IAW LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:INTERSHIELD PRORECO, PRA600/A1/A1
Kit Part:Y
CAGE:50411
CAGE:50411
CAGE:0TZA3
============= Composition/Information on Ingredients =============
Ingred Name:DIETHYLENETRIAMINE (MIBK) KETOMINE ADDUCT WITH PHENYL
GLYCIDYL ETHER
CAS:68541-07-1
Fraction by Wt: 50-100%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DIETHYLENETRIAMINE
CAS:111-40-0
RTECS #:IE1225000
Fraction by Wt: 1-10%
OSHA PEL:1 PPM
ACGIH TLV:1 PPM, S
Ingred Name:VENT: B) REMOVE VOLATILES PRODUCED DURING CURE &
DECOMPOSITION PRODUCTS PRODUCED DURING WELDING OR CUTTING ON (ING
4)
RTECS #:9999999ZZ
Ingred Name:ING 3: SURFACES COATED WITH THIS PRODUCT.
RTECS #:9999999ZZ
Ingred Name:EYE PROT: & FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: CAUSES NOSE AND THROAT
IRRITATION. EYE CONTACT: CAUSES EYE BURNS. SKIN CONTACT: CAUSES
SKIN BURNS. INGESTION: CAN RESULT IN IRRITATION OF THE MOUTH,
STOMACH TISSUE AND DIGESTIVE TRACT.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:IN ALL CASES OF DOUBT OR WHEN SYMPS PERSIST, SEEK MED ATTN.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCON PERSON. INHAL: REMOVE TO
FRESH AIR. IF DISCOMFORT IS PRESENT OR BREATHING IS ABSENT GET MED
ATTN IM MED. EYES: FLUSH IMMED W/PLENTY OF WATER FOR AT LEAST 15
MINUTES UNTIL IRRIT SUBSIDES. IF IRRIT PERSISTS, GET MED ATTN.
SKIN: FLUSH W/LARGE AMTS OF WATER. USE SOAP IF AVAIL. REMOVE
SEVERELY (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:106F,41C
Lower Limits:9999%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT, SPARKS, ELECTRICAL
EQUIP & OPEN FLAME. CLOSED CNTNRS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT. IN ABSENCE OF ELECTRICITY, A WATER (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILLED LIQUID W/SAND OR EARTH. DO NOT
USE COMBUSTIBLE MATERIALS SUCH AS SAWDUST. ABSORB SPILL W/AN INERT
MATERIAL (EG, DRY SAND OR EARTH) THEN PLACE IN A CHEMICAL WASTE
CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. LOOSEN CLOSURE
CAUTIOUSLY BEFORE OPENING. STORE IN A COOL, WELL VENTILATED PLACE
AWAY FROM INCOMPATIBLE MATERIALS.
Other Precautions:KEEP AWAY FROM HEAT, SPARKS & FLAMES. PROTECT MATL
FROM DIRECT SUNLIGHT. GROUND & BOND CONTAINERS WHEN TRANSFERRING
MATLS. EMPTY CONTAINERS MAY RETAIN HAZARDOUS PROPERTIES. FOLLOW ALL
MSDS/LABEL WARNI NGS, EVEN AFTER CNTNR IS EMPTIED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH APPROVED RESPIRATOR IN ACCORDANCE
WITH 29 CFR 1910.134 TO REMOVE PARTICULATES (AND VAPORS IF THERE IS
OVEREXPOSURE TO VAPORS GENERATED DURING THE PROCESSING OF THIS
PRDUCT.)
Ventilation:PRIVIDE SUFFICIENT VENT, IN VOLUME & PATTERN, TO A) KEEP
TLV OF HAZARDOUS INGREDS BELOW THE LIMITS SPECIFIED (ING 3)
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER . AS
NEEDED, USE BODY PROTECTION TO AVOID CONTACT WITH PRODUCT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ: SPRAY (FOG NOZZLE IS PREFERRED) MAY BE USED TO COOL CNTNRS.
DECOMP & COMBUST PRODS MAY BE TOXIC. FIRST AID PROC: CONTAM CLTHG
(INCLUDING SHOES) & WASH BEFORE REUSE. IF IRRIT PERSISTS, GET M ED
ATTN. INGEST: IF SWALLOWED, DO NOT INDUCE VOMITING. KEEP AT REST.
GET PROMPT MED ATTN.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:9999F,5537C
Vapor Density:HVR/AIR
Spec Gravity:1.008
Evaporation Rate & Reference:SLOWER/ETHER
Appearance and Odor:LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY PRDCE HAZARDOUS FUMES WHEN HEATED
TO DECOMPOSITION AS IN WELDING. FUMES MAY PRDCE CARBON MONOXIDE &
CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. DO NOT INCINERATE UNOPENED CONTAINERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:199 6958 DEVELOPER, MX 1620 TO MAKE 25 LITERS, PART A
Kit Part:Y
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM SULFITE
CAS:7757-83-7
RTECS #:WE2150000
Fraction by Wt: 70-75%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM METABORATE TETRAHYDRATE
CAS:10555-76-7
Fraction by Wt: 20-25%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG BORATE/M3
ACGIH TLV:5 MG BORATE/M3
Ingred Name:PENIETIC ACID, PENTA SODIUM SALT
CAS:140-01-2
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:HYDROXYMETHYL-4-METHYL-1-PHENYL-3-PYRAZOLIDONE
CAS:13047-13-7
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 566 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTAINS
4-HYDROXYMETHYL-4-METHYL-1-PHENYL-3-PYRAZOLINONE WHICH MAY CAUSE
BLOOD, TESTICULAR AND ADVERSE REPRODUCTIVE EFFECTS. CONTAINS SODIUM
SULFITE WHICH LIBERATES SULFUR DIOXIDE WHICH IS IRRITATINGTO THE
RESPIRATORY TRACT. MAY CAUSE SKIN/EYE IRRITATION, ALLERGIC SKIN
REACTION. HARMFUL IF SWALLOWED.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:BLOOD/TESTICULAR/REPRODUCTIVE EFFECTS,
RESPIRATORY TRACT IRRITATION, MUCOUS MEMBRANE IRRITATION, EYE
IRRITATION, ALLERGIC SKIN REACTION, WHEEZING, CHEST TIGHTNESS,
STOMACH UPSET, HIVES, FAINTNESS, WEA KNESS, DIARRHEA.
Medical Cond Aggravated by Exposure:SOME ASTHMATICS OF
SULFITE-SENSITIVE INDIVIDUALS MAY EXPERIENCE WHEEZING OR CHESST
TIGHTNESS.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMEEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: INDUCE VOMITING AS DIRECTED BY MEDICAL PERSONNEL. NEVER
GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. CALL PHYSICIAN OR
POISON CONTROL ASAP.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:NONFLAMMABLE. USE EXTINGUISHING MEDIA SUITABLE FOR
SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER IF
ALLOWABLE. OTHERWISE, SWEEP UP AND PLACE IN A CONTAINER FOR
CHEMICAL WASTE. CLEAN SURFACE THOROUGHLY TO REMOVE RESIDUAL
CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING DUST. AVOID CONTACT
WITH EYES, SKIN AND CLOTHING. USE WITH ADEQUATE VENTILATION. KEEP
AWAY FROM INCOMPATIBLE SUBSTANCES.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS DO NOT MAINTAIN AIRBORNE
CONCENTRATIONS BELOW RECOMMENDED EXPOSURE LIMITS, AN APPROVED
RESPIRATOR MUST BE WORN. RESPIRATOR TYPE: DUST. IF RESPIRATORS ARE
USED, A PROGRAM SHOULD BE INSTITUTED.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
KEY1:N1.
================== Physical/Chemical Properties ==================
HCC:F8
Boiling Pt:B.P. Text:NOT GIVEN
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:NEGLIGIBLE
Vapor Density:NEGLIGIBLE
Spec Gravity:NOT GIVEN
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:SOLID OFF-WHITE POWDER, NO ODOR
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
NITROGEN OXIDES, SULFUR DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:CAN BE INCINERATED WHEN IN COMPLIANCE WITH LOCAL
REGULATIONS. CONTRACT WITH A LICENSED CHEMICAL DISPOSAL AGENCY.
DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT TO NATIONAL, STATE
OR LOCAL LAWS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:A3125, 8-ANILINO-1-NAPHTHALENE SULFONIC ACID
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:8-ANILINO-1-NAPHTHALENESULFONIC ACID AMMONIUM
CAS:28836-03-5
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE HARMFUL BY INHALATION,
INGESTION OR SKIN ABSORPTION. CAUSES EYE AND SKIN IRRITATION.
MATERIAL IS IRRITATING TO MUCOUS MEMBRANES AND UPPER RESPIRATORY
TRACT. THE CHEMICAL, PHYSICAL, AND TOXICOLO GICAL PROPERTIES HAVE
NOT BEEN THOROUGHLY INVESTIGATED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT
LEAST 15 MINUTES. SKIN:IMMEDIATELY WASH WITH SOAP AND COPIOUS
AMOUNTS OF WATER. INHALATION:REMOVE TO FRESH AIR. IF NOT BREATHING
GIVE ARTIFI CIAL RESPIRATION. INGESTION:WASH OUT MOUTH WITH WATER
PROVIDED PERSON IS CONSCIOUS. CALL A PHYSICIAN. WASH CONTAMINATED
CLOTHING BEFORE REUSE.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY. CARBON DIOXIDE, DRY CHEMICAL POWDER OR
APPROPRIATE FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS,
HOLD FOR WASTE DISPOSAL. AVOID RAISING DUST. VENTILATE AREA AND
WASH SPILL SITE AFTER MATERI AL PICKUP IS COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT AND INHALATION. DO NOT
GET IN EYES, ON SKIN, ON CLOTHING. IRRITANT. HARMFUL SOLID. KEEP
TIGHTLY CLOSED. STORE IN A COOL, DRY PLACE.
Other Precautions:WEAR SUITABLE PROTECTIVE CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
MFR TRADE/PART#:AMMONIUM.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:>468F,>242C
Appearance and Odor:OLIVE-GREEN POWDER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STONG OXIDIZING AGENTS. STRONG ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF:CARBON MONOXIDE, CARBON
DIOXIDE, NITROGEN OXIDES, SULFURIC OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE OR MIX THE MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. OBSERVE ALL FEDERAL, STATE AND LOCAL
LAWS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:108 1785 EKTACOLOR RA BLEACH FIX AND REPLENISHER NR, WS
Kit Part:Y
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 60-70%
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMMONIUM THIOSULFATE
CAS:7783-18-8
RTECS #:XN6465000
Fraction by Wt: 10-20%
Other REC Limits:NONE RECOMMENDED
Ingred Name:FERRIC AMMONIUM ETHYLENEDIAMINETETRAACETIC ACID
CAS:21265-50-9
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ACETIC ACID (CERCLA)
CAS:64-19-7
RTECS #:AF1225000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 PPM
ACGIH TLV:10 PPM/15 STEL; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SODIUM BISULFITE (SASA III) (CERCLA)
CAS:7631-90-5
RTECS #:VZ2000000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): NOT GIVEN
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. MAY CAUSE TRANSIENT EYE IRRITATION. LOW
SKIN CONTACT HAZARD FOR RECOMMENDED HANDLING. EXPECTED TO BE A LOW
INGESTION HAZARD.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMMEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL
FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY PRODUCE
HAZARDOUS DECOMPOSTION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER IF ALLOWABLE WITH LARGE AMOUNTS
OF WATER. OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT
MATERIAL, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN
SURFACE TO REMOVE RESIDUA L CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE ONLY WITH ADEQUATE VENTILATION.
WASH THOROUGHLY AFTER HANDLING. KEEP FROM CONTACT WITH OXIDIZING
MATERIALS. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:KEEP AWAY FROM INCOMPATIBLE MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
THIS ENTRY FOR WORKING SOLUTION.
================== Physical/Chemical Properties ==================
HCC:C3
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.15
pH:5.0
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID, SLIGHT SULFUR DIOXIDE ODOR
Percent Volatiles by Volume:60-70%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, BASES, ACIDS, SODIUM HYPOCHLORITE (BLEACH).
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN, OXIDES OF SULFUR, AMMONIA, CHLORAMINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. MAY REQUIRE NEUTRALIZATION IF PH
< 2.0 OR PH > 12.5. DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE ANDLOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ROYCO 756D
CAGE:07950
CAGE:07950
============= Composition/Information on Ingredients =============
Ingred Name:HYDROTREATED MIDDLE PETROLEUM DISTILLATE
CAS:64742-46-7
RTECS #:JN9379645
Fraction by Wt: 75-85%
Other REC Limits:NONE RECOMMENDED
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATE, SOLVENT REFINED
(SEVERE), LIGHT NAPHTHENIC, (NON-CARCINOGENIC - IARC)
CAS:64741-97-5
RTECS #:PY8041001
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYMERIC ADDITIVE IN OIL (MIXTURE OF PRODUCTS)
Fraction by Wt: 10-15%
Other REC Limits:NONE RECOMMENDED
Ingred Name:T-BUTYLPHENYL DIPHENYL PHOSPHATE
CAS:56803-37-3
Fraction by Wt: <0.5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TRIORTHOCRESYL PHOSPHATE
CAS:78-30-8
RTECS #:TD0350000
Fraction by Wt: <0.1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:S, 0.1 MG/M3
ACGIH TLV:S, 0.1 MG/M3; 9192
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV FOR OIL MIST IS 5MG/M3
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:MAY CAUSE MINIMAL
IRRITATION.SKIN:MAY CAUSE SKIN DISORDERS.HIGH PRESSURE INJECTION
MAY CAUSE TISSUE DAMAGE.INGEST:MAY CAUSE GI TRACT IRRITATION.MAY
CAUSE LUNG DAMAGE IF VOMITED AFTER INGESTING(AS PIRATION
PNEUMONITIS).INHAL:MAY CAUSE MILD RESPIRATORY IRRITATION.
Explanation of Carcinogenicity:NONE OF THE INGREDIENTS IN THIS PRODUCT
IS LISTED BY NTP, IARC OR OSHA AS A CARCINOGEN.
Effects of Overexposure:INJECTION: NECROSIS MAY BE EVIDENCED BY DELAYED
ONSET OF PAIN AND TISSUE DAMAGE A FEW HOURS FOLLOWING PRESSURE
INJECTION.ASPIRATION PNEUMONITIS:COUGHING,LABORED BREATHING,BLUISH
SKIN.
Medical Cond Aggravated by Exposure:BECAUSE OF ITS DEFATTING
PROPERTIES, PROLONGED AND REPEATED SKIN CONTACT MAY AGGRAVATE AN
EXISTING DERMATITIS.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH SOAP AND
WATER.MATERIAL INJECTED UNDER THE SKIN IS A MEDICAL
EMERGENCY.EYES:FLUSH WITH WATER FOR 15 MINUTES.GET MEDICLA
ATTENTION.INHAL:REMOVE TO FRESH AIR. GIVE OXYGEN OR ARTIFICIAL
RESPIRATION IF NEEDED.INGEST:DO NOT INDUCE VOMITING.GET PROMPT
QUALIFIED MEDICAL ATTENTION.IF SPONTANEOUS VOMITING OCCURS,KEEP
HEAD LOWER THAN HIPS.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:225F,107C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL. A DIRECT STREAM OF WATER MAY SPREAD BURNING LIQUID.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.COOL FIRE EXPOSED CONTAINERS WITH WATER
FOG.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE PERSONNEL. ELIMINATE IGNITION SOURCES.
VENTILATE AREA. WEAR PROTECTIVE CLOTHING AND EQUIPMENT. DIKE AND
CONTAIN. ABSORB IN INERT MATERIAL AND PLACE IN APPROPIATE DISPOSAL
CONTAINER AND COVER. W ASH AREA WITH SOAP AND WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP AWAY FROM HEAT, OPEN FLAMES AND STRONG
OXIDANTS. KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:AVOID EYE AND SKIN CONTACT. DO NOT BREATHE VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE ENVIRONMENTAL CONTROLS ARE LACKING OR IN
ENCLOSED SPACES USE EITHER A SELF-CONTAINED BREATHING APPARATUS OR
A NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC VAPORS AND
PARTICULATES,DEPENDING ON THE AIRBORN CONCENTRATION.
Ventilation:MECHANICAL (GENERAL) VENTILATION.
Other Protective Equipment:PROTECTIVE CLOTHING AS REQUIRED TO MINIMIZE
EXPOSURE FROM PROLONGED OR REPEATED CONTACT. EYE BATH AND SAFETY
SHOWER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE. DISCARD
CONTAMINATED SHOES
Supplemental Safety and Health
NOTE TO PHYSICIAN:IF MORE THAN 2MG/KG OF MATERIAL HAS BEEN INGESTED AND
VOMITING HAS NOT OCCURED,(1) INDUCE EMESIS WITH SUPERVISION OR
(2)USE GASTRIC LAVAGE WITH A CUFFED ENDOTRACHEAL TUBE(WHEN THERE
IS LOSS OF GAG REFLEX).
================== Physical/Chemical Properties ==================
HCC:V6
Vapor Pres:NEGLIGIBLE
Vapor Density:>1
Spec Gravity:0.85
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIQUID;RED;SLIGHT HYDROCARBON ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:AIRBORNE SOLID AND LIQUID
PARTICULATES, CARBON MONOXIDE, OTHER UNIDENTIFIED HYDROCARBON
PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LUBAR/GREASESTICK, HL
Preparer's Name:WILLIAM M. DOWNING
CAGE:75554
CAGE:75554
============= Composition/Information on Ingredients =============
Ingred Name:MIXTURE CONSISTING OF INGREDIENTS 2-5
RTECS #:9999999ZZ
Ingred Name:FATTY ACIDS
Ingred Name:GLYCERIDES
Ingred Name:PETROLEUM WAX
Ingred Name:PETROLEUM OILS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NO HAZARD IS EXPECTED FROM THE UNUSED
PRODUCT. ABRASIVE OR METAL DUST MAY IRRITATE SKIN OR DAMAGE OUTER
SURFACE OF EYE BY ABRASIVE ACTION. INGESTION MAY CAUSE
GASTROINTESTINAL DISTURBANCES.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SYMPTOMS WHICH MAY OCCUR FROM INADEQUATE
PROTECTION DURING A BUFFING OPERATION ARE DISTURBED EYE VISION OR
SKIN IRRITATION.
Medical Cond Aggravated by Exposure:DERMATITIS.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN: WASH
WITH SOAP AND WATER. INGEST: INDUCE VOMITING AND CONSULT MEDICAL
PERSONNEL. INHAL: REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE O*2/ARTF
RESP) (FP N).
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>350F,>177C
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL, CO*2.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:WATER OR FOAM MAY CAUSE VIOLENT FROTHING,
ESPECIALLY IF SPRAYED DIRECTLY INTO BURNING LIQUID.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROT CLTHG. RECLAIM FOR REUSE IF
POSSIBLE, OR SWEEP, SCOOP UP, AND CONTAINERIZE FOR LATER DISPOSAL.
THIS PRODUCT IS NOT A HAZARDOUS WASTE BY ITSELF, BUT BE SURE TO
CHECK IF IT HAS COME IN CONTACT W/HAZ SUBSTANCE OR MATL BEFORE
DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF SUN AND AWAY FROM HEAT
SOURCES.
Other Precautions:DURING A BUFFING OPERATION, USE AN EXHAUST, EYE PROT,
DURING BUFFING FROM ENTERING NOSE, THROAT &/OR SKIN OF OPERATOR.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DURING BUFFING OR BELT POLISHING USE NIOSH/MSHA
APPROVED DUST/MIST RESPIRATOR.
Ventilation:MECHANICAL(GEN): ADEQUATE FOR STORAGE AND HANDLING.
Other Protective Equipment:CLEAN WORKCLOTHES. EYE WASH.
Work Hygienic Practices:WASH AFTER PHYSICAL CONTACT AND BEFORE EATING.
Supplemental Safety and Health
SPEC GRAV: 0.8-0.85(H*2O=1).
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:>700F,>371C
Melt/Freeze Pt:M.P/F.P Text:>125F,>52C
Spec Gravity:SUPP DATA
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GREASY SOLID W/MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:TEMPERATURES OVER 350F.
Hazardous Decomposition Products:CARBON AND SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. WASTE GENERATED FROM A BUFFING OPERATION
CAN CONTAIN LINT WHICH MAY BE COMBUSTIBLE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PHENOL CHEMETS, VACUETTES & VACUVIALS, R801
CAGE:7K791
CAGE:7K791
============= Composition/Information on Ingredients =============
Ingred Name:BORATE (1-),TETRAHYDRO-,SODIUM (SODIUM BOROHYDRIDE)
CAS:16940-66-2
RTECS #:ED3325000
Fraction by Wt: <0.1%
Ingred Name:ANTIPYRINE, 4-AMINO
CAS:83-07-8
RTECS #:CD2480000
Fraction by Wt: 0.2%
Ingred Name:ACETIC ACID, (ETHYLENEDINITRILO) TETRA-,DISODIUM SALT
(DISODIUM ETHYLENEDIAMINE TETRAACETATE)
CAS:139-33-3
RTECS #:AH4375000
Fraction by Wt: 0.2%
Ingred Name:1,3-PROPANEDIOL, 2-AMINO-2-(HYDROXYMETHYL)- (THAM)
CAS:77-86-1
RTECS #:TY2900000
Fraction by Wt: 0.2%
Ingred Name:SODIUM CARBONATE (2:1)
CAS:497-19-8
RTECS #:VZ4050000
Fraction by Wt: 1.0%
Ingred Name:WATER (DEIONIZED)
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: >98.0%
Ingred Name:FERRATE (3-), HEXACYANO-, TRIPOTASSIUM (POTASSIUM
FERRICYANIDE). THE FOLLOWING INFORMATION PERTAINS TO THIS
INGREDIENT.
CAS:13746-66-2
RTECS #:LJ8225000
Fraction by Wt: 0.02%GMS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:UNKNOWN Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: MAY CAUSE DERMATITIS. EYE: MAY
CAUSE CONJUNCTIVITIS. INGEST: MAY CAUSE NAUSEA, VOMITING, SORE
THROAT, ABDOMINAL PAIN, AND DIARRHEA.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN: WASH AFFECTED AREAS WITH SOAP AND MILD DETERGENT AND
LARGE AMOUNTS OF WATER. EYE: FLUSH CONTINUOUSLY WITH COPIOUS
AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. FORCIBLY HOLD EYELIDS
APART TO ENSURE IRRIGATION OF ALL EYE AND LID TISSUE.CALL MD.
INGEST: IF VICTIM IS CONSCIOUS AND NOT CONVULSIVE, IMMEDIATELY GIVE
THE VICTIM LARGE QUANTITIES OF WATER. CALL MD.
===================== Fire Fighting Measures =====================
Flash Point:NON-COMBUSTIBLE
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, WATER SPRAY, OR
ALCOHOL FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SOLUBILITY IN WATER:SLOWLY SOLUBLE IN 2.5 PARTS COLD WATER.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:158 F (70C)
Spec Gravity:1.8 AT 39 F
Solubility in Water:SEE SUPP DATA.
Appearance and Odor:YELLOW OR RED CRYSTALLINE. MILD SALINE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:MAY BECOME UNSTABLE AT ELEVATED
TEMPERATURES AND PRESSURES. SLOWLY DECOMP IN AQUEOUS SOLNS.
PHOTOSENSITIVE.
Hazardous Decomposition Products:WHEN HEATED TO DECOMPOSITION OR ON
CONTACT W/ACIDS OR ACID FUMES; EMITS HIGHLY TOXIC FUMES OF
CYANIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF BY MEANS AS TO COMPLY WITH ALL LOCAL,
STATE AND FEDERAL REGULATIONS OR CONTACT AN APPROVED AND LICENSED
DISPOSAL AGENCY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CHLOROBENZENE
CAGE:BAXTE
CAGE:BAXTE
CAGE:2H215
============= Composition/Information on Ingredients =============
Ingred Name:CHLOROBENZENE (MONOCHLOROBENZENE) (CONFIRMED ANIMAL
CARCINOGEN BY NTP) *94-4*
CAS:108-90-7
RTECS #:CZ0175000
Fraction by Wt: 100%
Other REC Limits:75 PPM
OSHA PEL:350 MG/CUM
ACGIH TLV:46 MG/CUM IC
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION, LUNG, LIVER &
KIDNEY DAMAGE. EYES: MILD IRRITATION. SKIN: ABSORPTION, IRRITATION,
DERMATITIS. CHLOROBENZENE IS A MILD MUCOUS MEMBRANE IRRITANT & CNS
DEPRESSANT. ACUTE EXPOSURECAUSES NOSE IRRITATION.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, HEADACHE, DROWSINESS, DIZZINESS,
INTOXICATION, DEFATTING, DISCOMFORT, INCOORDINATION, LOSS OF
CONSCIOUSNESS, NARCOSIS
Medical Cond Aggravated by Exposure:LUNG, LIVER & KIDNEY DISEASES &
DERMATITIS SUSCEPTIBILITY
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. ADMINISTER CPR/OXYGEN AS
NEEDED. EYES: RINSE W/COPIOUS AMOUNTS OF WATER FOR AT LEAST 15
MINS. SKIN: FLUSH THOROUGHLY FOR AT LEAST 15 MINS. WASH W/SOAP &
WATER. INGESTI ON: NEVER INDUCE VOMITING/GIVE ANYTHINGBY MOUTH IF
UNCONSCIOUS/HAVING CONVULSIONS. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:84.2F
Lower Limits:1.3
Upper Limits:7.1
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING & SCBA. KEEP
FIRE-EXPOSED CONTAINERS COOL W/WATER SPRAY.
Unusual Fire/Explosion Hazard:HEAT WILL BUILD PRESSURE & MAY RUPTURE
CLOSED STORAGE CONTAINERS. AUTOIGNITION TEMP: 1180.4F
================== Accidental Release Measures ==================
Spill Release Procedures:PROTECT FROM IGNITION. WEAR PROTECTIVE
CLOTHING & USE APPROVED RESPIRATORY EQUIPMENT. ABSORB SPILLED
MATERIAL IN AN ABSORBENT RECOMMENDED FOR SOLVENT SPILLS & REMOVE TO
SAFE LOCATION FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT FROM TEMP EXTREMES & DIRECT
SUNLIGHT. BASE PROPER STORAGE ON OTHER MATERIALS STORED & THEIR
HAZARDS & POTENTIAL CHEMICAL INCOMPATIBILITY.
Other Precautions:STORE IN AN ACCEPTABLY PROTECTED & SECURE FLAMMABLE
LIQUID STORAGE ROOM. GROUND & BOND METAL CONTAINERS TO MINIMIZE
STATIC SPARKS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW NIOSH & EQUIPMENT MANUFACTURER'S
RECOMMENDATIONS TO DETERMINE APPROPRIATE AIR-PURIFYING,
AIR-SUPPLIED/SCBA EQUIPMENT.
Ventilation:LOCAL/GENERAL TO KEEP EXPOSURE LEVELS BELOW PEL & MINIMIZE
FIRE HAZARDS DEPENDING ON CONDITIONS OF USE & QUANTITY USED
Other Protective Equipment:EYE WASH FOUNTAINS, SAFETY SHOWERS
Work Hygienic Practices:REMOVE & LAUNDER CONTAMINATED CLOTHING. DISCARD
CONTAMINATED SHOES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:269.06F
Melt/Freeze Pt:M.P/F.P Text:-50.044
Vapor Pres:8.8
Vapor Density:3.9
Spec Gravity:1.106
Evaporation Rate & Reference:(BU AC=1): 1
Solubility in Water:0.05%
Appearance and Odor:CLEAR, COLORLESS LIQUID W/SLIGHT ALMOND-LIKE ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS & STRONG ACIDS
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, OPEN CONTAINERS,
POOR VENTILATION
Hazardous Decomposition Products:CO, PHOSGENE, HYDROGEN CHLORIDE &
OTHER TOXIC VAPORS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AS AN EPA HAZARDOUS WASTE IN
ACCORDANCE W/FEDERAL, STATE & LOCAL REGULATIONS. EPA HAZARDOUS
WASTE NOS: U037(IGNITABLE, TOXIC), D001(IGNITABLE). UN1134
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CRAMER TUF-SKIN (COLORLESS & ORIGINAL) (SEE SUPPL)
Kit Part:Y
Preparer's Name:NOT PROVIDED
CAGE:24719
CAGE:24719
Contract Num:MDA414-99-T-3473
CAGE:0ZA42
============= Composition/Information on Ingredients =============
Ingred Name:HYDROCARBON PROPELLANT (ISOBUTANE, 75-28-5; PROPANE,
74-98-6; N-BUTANE, 106-97-8)
RTECS #:9999999ZZ
> Wt:25.
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:1000 PPM
Ingred Name:ISOPROPYL ALCOHOL
CAS:67-63-0
RTECS #:NT8050000
> Wt:60.
Other REC Limits:NOT PROVIDED
OSHA PEL:980 MG/M3;400 PPM
ACGIH TLV:983 MG/M3;400 PPM
ACGIH STEL:1230 MG/M3;500 PPM
Ingred Name:WW GUM ROSIN
CAS:8050-09-7
RTECS #:VL0480000
> Wt:10.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NONE ESTABLISHED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT PROVIDED
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EFFECTS OF ACUTE OVEREXPOSURE FOR
ISOPROPYL ALCOHOL: EYES-CAN CAUSE SEVERE IRRITATION.
SKIN-PROLONGED OR REPEATED CONTACT CAN CAUSE MODERATE IRRITATION,
DEFATTING, DERMATITIS. BREATHING-EXCESSIVE INH ALATION OF VAPORS
CAN CAUSE NASAL AND RESPIRATORY IRRITATION, POSSIBLE
UNCONSCIOUSNESS, EVEN DEATH. SWALLOWING-CAN CAUSE GASTROINTESTINAL
IRRITATION. EFFECTS OF CHRONIC OVEREXPOSURE: ISOPROPYL ALCOHOL HAS
BEEN FOUND TO CAUSE DAMAGE TO THE LIVER, KIDNEYS AND BRAIN OF
LABORATORY ANIMALS.
Explanation of Carcinogenicity:NOT PROVIDED
Effects of Overexposure:EYES-CAN CAUSE SEVERE IRRITATION.
SKIN-PROLONGED OR REPEATED CONTACT CAN CAUSE MODERATE IRRITATION,
DEFATTING, DERMATITIS. BREATHING-EXCESSIVE INHALATION OF VAPORS CAN
CAUSE NASAL AND RESPIRATORY IRR ITATION, POSSIBLE UNCONSCIOUSNESS,
EVEN DEATH. SWALLOWING-CAN CAUSE GASTROINTESTINAL IRRITATION.
Medical Cond Aggravated by Exposure:NOT PROVIDED
======================= First Aid Measures =======================
First Aid:IF IN EYES: FLUSH WITH LARGE AMOUNT OF WATER. CAUTIOUSLY
ATTEMPT TO LIFT UPPER AND LOWER LIDS OCCASIONALLY, GET MEDICAL
ATTENTION IMMEDIATELY. IF ON SKIN: THOROUGHLY WASH EXPOSED AREA
WITH SOAP AND WA TER. IF BREATHED: REMOVE TO FRESH AIR; ADMINISTER
OXYGEN. CONSULT PHYSICIAN IMMEDIATELY. IF SWALLOWED: IMMEDIATELY
DRINK TWO GLASSES OF WATER AND INDUCE VOMITING. GET MEDICAL
ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:=-45.6C, -50.F
Lower Limits:2
Upper Limits:12
Extinguishing Media:CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:THIS IS AN AEROSOL PRODUCT. USE PROCEDURES FOR
FLAMMABLE AEROSOLS.
Unusual Fire/Explosion Hazard:CONTENTS ARE FLAMMABLE AND UNDER
PRESSURE. IF RELEASED WOULD ADD TO FIRE INTENSITY. RUPTURING
CONTAINERS MAY BECOME PROJECTILES.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. SMALL
SPILLS SHOULD BE FLUSHED WITH LARGE QUANTITIES OF WATER. LARGER
SPILLS SHOULD BE COLLECTED FOR DISPOSAL.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:PRODUCT IS AN AEROSOL. DO NOT USE NEAR
FIRE, FLAME OR HOT SURFACES. DO NOT PUNCTURE OR INCINERATE. DO NOT
EXPOSE TO HEAT OR STORE >120F.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED IN NORMAL USE. AS WITH ALL SPRAYS,
BREATHING MIST SHOULD BE AVOIDED.
Ventilation:USE IN WELL VENTILATED AREA.
Other Protective Equipment:NOT REQUIRED
Work Hygienic Practices:NOT PROVIDED
Supplemental Safety and Health
THIS IS A KIT. THE OTHER MSDS SERIAL NUMBERS: CLNFL, CLNFH, CLNDX
================== Physical/Chemical Properties ==================
HCC:F2
NRC/State Lic Num:NOT RELEVANT
Decomp Temp:Decomp Text:NOT PROVIDED
Vapor Pres:2586 MM HG (IN CAN)
Vapor Density:<1
Viscosity:NOT PROVIDED
Evaporation Rate & Reference:~2.3 (BUAC = 1)
Solubility in Water:PARTIAL
Appearance and Odor:CLEAR SPRAY WITH SCENTED ALCOHOL ODOR AND STICKY
RESIDUE
Percent Volatiles by Volume:>85
Corrosion Rate:NOT PROVIDED
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ANHYDRIDES, ISOCYANATES, ORGANOMETALLICS, OXYGEN AND OXIDIZERS
Stability Condition to Avoid:AVOID HEAT, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:THERMAL DECOMPOSITION OR BURNING MAY
PRODUCE CARBON DIOXIDE,CARBON MONOXIDE
=================== Toxicological Information===================
Toxicological Information:NOT PROVIDED
===================== Ecological Information =====================
Ecological:NOT PROVIDED
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF PRODUCT IIN ACCORDANCE WITH
APPLICABLE FEDERAL, STATE, COUNTY AND LOCAL REGULATIONS
=================== MSDS Transport Information ===================
Transport Information:NOT PROVIDED
===================== Regulatory Information =====================
SARA Title III Information:NOT PROVIDED
Federal Regulatory Information:NOT PROVIDED
State Regulatory Information:NOT PROVIDED
======================= Other Information =======================
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:NICKELOUS CHLORIDE,6-HYDRATE,2768
CAGE:HO851
CAGE:HO851
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:NICKELOUS CHLORIDE HEXAHYDRATE
CAS:7791-20-0
RTECS #:QR6480000
Fraction by Wt: 90- 100%
OSHA PEL:O.1 MG/M3
ACGIH TLV:0.1 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:UNKNOWN OSHA:NO
Health Hazards Acute and Chronic:INHALE-CAUSES IRRITATION TO THE
RESPIRATORY TRACT. LUNG DAMAGE. INGEST-TOXIC. CAPILLARY DAMAGE,
MYOCARDIAL WEAKNESS, CENTRAL NERVOUS SYSTEM DEPRESSION, KIDNEY &
LIVER DAMAGE. SKIN-CAUSES IRRITATION, D ERMATITIS. EYE-CAUSES
IRRITATION.
Explanation of Carcinogenicity:AN IARC ANTICIPATED CARCINOGEN.
Effects of Overexposure:INHALE-METALLIC TASTE IN MOUTH, COUGHING, SORE
THROAT & SHORTNESS OF BREATH. INGEST-ABDOMINAL PAIN, DIARRHEA,
NAUSEA & VOMITING, GIDDINESS. SKIN-ITCHING, REDNESS OR RASH.
EYE-REDNESS, PAIN.
Medical Cond Aggravated by Exposure:PERSONS WITH PREEXISTING SKIN
DISORDERS, IMPAIRED RESPIRATORY OR PULMONARY FUNCTIONS OR WITH
HISTORY OF STHMA, ALLERGIES OR SENSITIZATION TO NICKEL MAY BE AT
INCREASED RISK UPON EXPOSURE TO SUBSTANCE.
======================= First Aid Measures =======================
First Aid:INHALE-REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN GET MEDICAL
AID. INGEST-INDUCE VOMITING IMMEDIATELT AS DIRECTED BY MEDICAL
PERSONNEL.GET MEDICAL AID. SKIN-IMMEDIATELY FLUSHSKIN WITH PLENTY
OF WATER FOR 15 MIN. REMOVE CONTAMINATED CLOTHES/SHOES. GET MEDICAL
AID. EYE-IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR 15 MIN. GET
MEDICAL AID
===================== Fire Fighting Measures =====================
Flash Point:NOT RELEVANT
Extinguishing Media:USE ANY MEANS SUITABLE FOR EXTINGUISHING
SURROUNDING FIRE.
Fire Fighting Procedures:IN THE EVEBT OF FIRE WEAR FULL PROTECTIVE
CLOTHING & NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS WITH
FULL FACEPIECE OPERATED IN THE PRESSURE DEMAND MODE.
Unusual Fire/Explosion Hazard:NOT CONSIDERED TO BE AN EXPLOSION HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA OF LEAK OR SPILL. WEAR
APPROPIATE PERSONAL PROTECTIVE EQUIPMENT. SWEEP UP AND CONTAINERIZE
FOR RECLAMATION OR DISPOSAL. VACUUMING OR WET SWEEPING MAY BE USED
TO AVOID DUST DISPERSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN TIGHTLY CLOSED CONTAINER,
STORED IN A COOL, DRY, VENTILATED AREA. PROTECT AGANIST PHYSICAL
DAMAGE. ISOLATE FROM INCOMPATIBLES.
Other Precautions:SOLUTIONS ARE ACIDIC. AVOID CROSS CONTAMINATION OF
STREET CLOTHES. WASH HANDS BEFORE EATING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF AIRBORNE CONCENTRATION EXCEEDS TLV,
RESPIRATORY PROTECTION IS REQUIRED. AT CONCENTRATIONS UP TO 1 PPM,
A NIOSH-APPROVED DUST MASK IS RECOMMENDED. ABOVE THIS LEVEL, A
NIOSH-APPROVED SELF-CONTAINED B REATHING APPARATUS IS ADVISED.
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO MEET TLV
REQUIREMENTS.
Other Protective Equipment:UNIFORM, APRON, EYEBATH, SAFETY SHOWER
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
TOXIC SOLID.
================== Physical/Chemical Properties ==================
HCC:T3
NRC/State Lic Num:NOT RELEVANT
Spec Gravity:3.55
Evaporation Rate & Reference:NOT RELEVANT
Solubility in Water:COMPLETE (100%)
Appearance and Odor:GREEN CRYSTALLINE POWDER
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
VIOLENT REACTION WITH POTASSIUM.
Stability Condition to Avoid:SUBSTANCE WILL PICK UP MOISTURE FROM THE
AIR AND GO INTO SOLUTION IF EXPOSED ON OPEN CONTAINERS.
Hazardous Decomposition Products:OXIDES OF THE CONTAINED METAL AND
HALOGEN, POSSIBLY ALSO FREE OR IONIC HALOGENS.
Conditions to Avoid Polymerization:MOISTURE AND INCOMPATIBLES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. REPORTABLE QUANTITY (RQ) IS 100 LBS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ENAMEL: LUSTERLESS, QUICK DRY, STYRENATED ALKYD,YELLOW 33538
Preparer's Name:ERNEST CARTER
CAGE:61196
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:V.M.&P. NAPHTHA
CAS:64742-89-8
Code:F
= Wt:29.
OSHA PEL:300 PPM
ACGIH TLV:300
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
= Wt:5.
OSHA PEL:SEE TABLE Z-2
ACGIH TLV:188 MG/M3;50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE
CAS:1330-20-7
RTECS #:ZE2100000
= Wt:1.
OSHA PEL:100
ACGIH TLV:434 MG/M3;100 PPM
ACGIH STEL:651 MG/M3;150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:2-METHYL-1-PROPANOL
CAS:78-83-1
RTECS #:NP9625000
= Wt:4.
OSHA PEL:300 MG/M3;100 PPM
ACGIH TLV:152 MG/M3;50 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:COBALT 2-ETHYLHEXANOATE (1:2)
CAS:136-52-7
= Wt:.2
Ingred Name:N-BUTYL ACETATE
CAS:123-86-4
RTECS #:AF7350000
= Wt:2.
OSHA PEL:710 MG/M3;150 PPM
ACGIH TLV:713 MG/M3;150 PPM
ACGIH STEL:950 MG/M3;200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
= Wt:.4
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3
Ingred Name:CRISTOBALITE
CAS:14464-46-1
RTECS #:VV7325000
= Wt:4.
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.05 MG/M3
Ingred Name:TALC
CAS:14807-96-6
RTECS #:WW2710000
= Wt:12.
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:2 MG/M3
Ingred Name:LEAD CHROMATE
CAS:1344-37-2
Code:F
= Wt:18.
OSHA PEL:0.05MG/M3
ACGIH TLV:0.05
Ingred Name:LEAD (AS PB)
= Wt:12.02
OSHA PEL:0.05MG/M3
ACGIH TLV:0.15
Ingred Name:CHROMIUM VI (AS CR)
= Wt:2.56
ACGIH TLV:0.05
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE
Health Hazards Acute and Chronic:EXPOSURE MAY BE BY INHALATION AND/OR
SKIN OR EYE CONTACT, DEPENDING ON CONDITIONS OF USE. TO MINIMIZE
EXPOSURE, FOLLOW RECOMMENDATIONS FOR PROPER USE, VENTILATION, AND
PERSONAL PROTECTIVE EQUIPMENT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION OF EYES, SKIN AND RESPIRATORY
SYSTEM. MAY CAUSE NERVOUS SYSTEM DEPRESSION. EXTREME OVEREXPOSURE
MAY RESULT IN UNCONSCIOUSNESS AND POSSIBLY DEATH.
Medical Cond Aggravated by Exposure:MAY CAUSE ALLERGIC SKIN REACTION IN
SUSCEPTIBLE PERSONS OR SKIN SENSITIZATION.
======================= First Aid Measures =======================
First Aid:IF INHALED: REMOVE FROM EXPOSURE. RESTORE BREATHING. IF ON
SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP AND WATER. IF IN
EYES: FLUSH EYES WITH LARGE AMOUNTS OF WATER FOR 15 MINUTES. IF
SWALLOWED: GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:=6.7C, 44.F
Autoignition Temp:Autoignition Temp Text:NONE
Lower Limits:0.9
Upper Limits:10.9
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT INCLUDING
SELF-CONTAINED BREATHING APPARATUS SHOULD BE USED.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
TRANSFER ONLY TO APPROVED CONTAINERS WITH COMPLETE AND APPRO[RIATE
LABELING. DO NOT TAKE INTERNALLY. KEEP OUT OF THE REACH OF
CHILDREN.
Other Precautions:DO NOT APPLY ON TOYS AND OTHER CHILDREN'S ARTICLES,
FURNITURE, OR ANY INTERIOR SURFACE OF A DWELLING OR FACILITY WHICH
MAY BE OCCUPIED OR USED BY CHILDREN. DO NOT APPLY ON ANY EXTERIOR
SURFACE OF DWEL LING UNITS, SUCH AS WINDOW SILLS, PORCHES, STAIRS,
OR RAILINGS TO WHICH CHILDREN MAY BE COMMONLY EXP OSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A PROPERLY FITTED ORGANIC VAPOR/PARTICULATE
RESPIRATOR.
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF THE
EXPOSURE TO MATERIALS IN SECTION 11 IS MAINTAINED BELOW APPLICABLE
EXPOSURE LIMITS.
Other Protective Equipment:USE BARRIER CREAM ON EXPOSED SKIN.
Work Hygienic Practices:NONE
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:222-325 F
Melt/Freeze Pt:M.P/F.P Text:NONE
Decomp Temp:Decomp Text:NONE
Vapor Density:HEAVIER
Spec Gravity:1.19
VOC Pounds/Gallon:507
VOC Grams/Liter:4.23
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE
Percent Volatiles by Volume:65%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
OXIDES OF METALS IN SECTION11.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MUST BE TESTED FOR OGNITABILITY AND
EXTRACTABILITY TO DETERMINE THE APPLICABLE EPA HAZARDOUS WASTE
NUMBERS. INCINERATE IN APPROVED FACILITY. DO NOT INCINERATE CLOSED
CONTAINER. DISPOSE OF IN ACC ORDANCE WITH FEDERAL, STATE, AND LOCAL
REGULATIONS REGARDING POLLUTION.
===================== Regulatory Information =====================
State Regulatory Information:CALIFORNIA PROPOSITION65: THIS PRODUCT
CONTAINS
CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO
CAUSE CANCER AND BIRTH DEFECTS OR OTHER
REPRODUCTIVE HARM. TSCA CERTIFICATION.ALL
CHEMICALS IN THIS PRODUC T ARE LISTED, OR ARE EXEMPT
FROM LISTING, ON THE TSCA INVENTORY.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:F19 2-CHLOROETHYL VINYL ETHER
CAGE:84898
CAGE:84898
CAGE:8Y898
============= Composition/Information on Ingredients =============
Ingred Name:2-CHLOROETHYLVINYL ETHER
CAS:110-75-8
RTECS #:KN6300000
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT/MOUSE): 250 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: MAY BE RAPIDLY
ABSORBED/HARMFUL/IRRITATION/SENSITIZATION/ALLERGIC REACTION.
INHALATION: HARMFUL/RESPIRATORY TRACT/MUCOUS MEMBRANE
IRRITATION/ALLERGIC RESPIRATORY REACTION, DELAYED LUNG INJURY. I
NGESTION: HARMFUL/GI DISTURBANCES. EYES: IRRITATION/SEVERE
BURNS/INJURY. CAN CAUSE DELAYED ADVERSE HEALTH EFFECTS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, BURNS, SEVERE INFLAMMATION,
SWELLING, BURNINGS SENSATION, COUGHING, WHEEZING, LARYNGITIS,
SHORTNESS OF BREATH, HEADACHE, NAUSEA, VOMITING.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15-20 MINS. SKIN: FLUSH W/WATER FOR
15-20 MINS. IF NOT BURNED, WASH W/SOAP & WATER TO CLEANSE.
INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED &
CONTINUE UNTIL MEDIC AL ASSISTANCE ARRIVES. KEEP WARM & QUIET.
INGESTION: DON'T GIVE LIQUIDS/INDUCE VOMITING IF
UNCONSCIOUS/CONVULSING. IF VOMITING OCCURS, WATCH CLOSELY TO AVOID
AIRWAY OBSTRUCTION. (SEE SUPP)
===================== Fire Fighting Measures =====================
Flash Point:60.8F
Extinguishing Media:CO2, DRY CHEMICAL POWDER. DON'T USE WATER.
Unusual Fire/Explosion Hazard:FLAMMABLE CHEMICAL. VAPORS TRAVEL TO
DISTANT IGNITION SOURCE/FLASH BACK. CONTAINER MAY EXPLODE UNDER
FIRE CONDITIONS/FORMS EXPLOSIVE MIXTURE IN AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR APPRORPRIATE OSHA
REGULATED EQUIPMENT. VENTILATE AREA. ABSORB ON VERMICULITE/SIMILAR
MATERIAL. SWEEP UP & PLACE IN APPROPRIATE CONTAINER/HOLD FOR
DISPOSAL. WASH CONTAMINATED SURFAC ES TO REMOVE ANY RESIDUES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL DRY PLACE ONLY
W/COMPATIBLE CHEMICALS. KEEP TIGHTLY CLOSED.
Other Precautions:AVOID CONTACT W/SKIN, EYES & CLOTHING. DON'T BREATH
VAPORS. CONTACT LENSES SHOULDN'T BE WORN IN THE LABORATORY. ALL
CHEMICALS SHOULD BE CONSIDERED HAZARDOUS. AVOID DIRECT PHYSICAL
CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE OSHA/MSHA APPROVED SAFETY
EQUIPMENT.
Ventilation:CHEMICAL SHOULD BE HANDLED ONLY IN A HOOD.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
PRODUCT IS EASILY OXIDIZED & MAY BE A PEROXIDE FORMER, CHECK FOR
PEROXIDES ON ALL OPENDED SAMPLES. FIRST AID CONT'D: OBTAIN MEDICAL
ATTENTION IN ALL CASES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:228.2F
Melt/Freeze Pt:M.P/F.P Text:-94F
Appearance and Odor:COLORLESS-PALE YELLOW LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES/OXIDIZING AGENTS.
Stability Condition to Avoid:FIRE, HEAT, ACIDIC CONDITIONS.
Hazardous Decomposition Products:TOXIC FUMES, DECOMPOSITION PRODUCTS
ARE CORROSIVE.
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED W/AN
AFTERBURNER & SCRUBBER IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:WATER-REDUCIBLE HIGH BAKE TEXTURE ENAMEL, (SUPP DATA)
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 0-20%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:SUPP DATA:APPLICABLE LIMITS FOR NUISANCE DUSTS ARE ACGIH
TLV 10 MG/M3 (TOTAL DUST), OSHA PEL 15 MG/M3 (TOTAL (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: DUST), 5 MG/M3 (RESPIRABLE FRACTION).
RTECS #:9999999ZZ
Ingred Name:RESP PROT: APPROVED DUST/MIST RESPIRATOR FOR DUST WHICH MAY
BE GENERATED FROM THIS PRODUCT, UNDERLYING PAINT (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: OR THE ABRASIVE.
RTECS #:9999999ZZ
Ingred Name:VENT: EXPOSURE LIMITS. REFER TO OSHA STANDARDS 1910.94,
1910.107, 1910.108.
RTECS #:9999999ZZ
Ingred Name:ETHANOL, 2-(2-BUTOXYETHOXY)-; (DIETHYLENE GLYCOL MONOBUTYL
ETHER). VP: 0.1
CAS:112-34-5
RTECS #:KJ9100000
Fraction by Wt: 5-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 0-20%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRIT OF EYES, SKIN & UPPER RESP
SYSTEM. IN A CONFINED AREA VAPS IN HIGH CONC MAY CAUSE HEADACHE,
NAUSEA OR DIZZINESS. CHRONIC:CYRSTALLINE SILICA (QUARTZ,
CRISTOBALITE) IS LISTED BY IARC. LONG T ERM EXPOSURE TO HIGH LEVELS
OF SILICA DUST, WHICH CAN OCCUR ONLY WHEN SANDING OR ABRADING THE
DRY FILM,(EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE (QUARTZ): GROUP 2A
(IARC 7,341,87), ANTICIPATED TO BE A CARCINOGEN (NTP 6'TH ANN RPT
'91).
Effects of Overexposure:EFTS OF OVEREXP:MAY CAUSE LUNG DMG (SILICOSIS)
& POSSIBLY CANCER. RATS EXPOSED TO TITANIUM DIXOIDE DUST @ 250
MG/M3 DEVELOPED LUNG CANCER, HOWEVER, SUCH EXPOSURE LEVELS ARE NOT
ATTAINABLE IN THE WORKP LACE. SIGNS & SYMPS:REDNESS &
ITCHING/BURNING SENS MAY INDICATE EYE/EXCESS SKIN EXPOSURE.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM AND
QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP AND WATER.
REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE RE-USE. EYE: FLUSH
EYE WIT H LARGE AMOUNTS OF WATER FOR AT LEAST 15 MIN. GET MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>199F,>93C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER SPRAY MAY BE INEFTIVE. IF WATER IS USED, FOG NOZZLES
PREFERABLE. WATER MAY BE USED TO (SUPP DATA)
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO THE
BUILD-UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNR CLSD WHEN NOT IN USE.
TRANSFER ONLY TO APPRVD CNTNRS W/COMPLETE & APPROP LABELING. DO NOT
TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:USE ONLY WITH ADEQUATE VENTILATION. AVOID BREATHING
VAPOR AND SPRAY MIST. AVOID CONTACT WITH SKIN AND EYES. THIS
COATING MAY CONTAIN MATLS CLASSIFIED AS NUISANCE PARTICULATES, SUCH
AS TITANIUM DIOXIDE OR CALCIUM CARBONATE, WHICH (SUPP DATA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENT, WEAR NIOSH/MSHA APPRVD PROPERLY FITTED
ORGANIC VAPOR/PARTICULATE RESP FOR PROT AGAINST MATLS IN INGRED
SECT. WHEN SANDING/ABR ADING DRIED FILM, WEAR NIOSH/MSHA(ING 7)
Ventilation:LOC EXHST PREFERBLE. GEN EXHST ACCEPTABLE IF THE EXPOSURE
TO MATLS IN INGRED SECT IS MAINTAINED BELOW APPLIC (ING 9)
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
MFR TRADE NAME/PART NO: F83 T 513 FLATTING CLEAR. FIRE FIGHT PROC: COOL
CLSD CNTNRS TO PVNT PRESSURE BUILD-UP & POSSIBLE AUTOIGNIT OR
EXPLOSION WHEN EXPOSED TO EXTREME HEAT. OTHER PREC: MAY BE PRESENT
AT HAZ LEVELS DURING SANDING OR ABRADING OF THE DRIED FILM. IF NO
SPECIFIC DUSTS ARE LISTED IN INGRED SECT, THE (ING 4)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:SEE ING
Vapor Density:HVR/AIR
pH:9
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:67-74
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THIS PRODUCT IS NOT HAZARDOUS AS
DEFINED UNDER THE RCRA 40 CFR 261. INCINERATE IN APPROVED FACILITY.
DO NOT INCINERATE CLOSED CONTAINER. DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE AND LOC AL REGULATIONS REGARDING POLLUTION.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: HIT HY 150, PART A
Kit Part: Y
Cage: 11239
Box: 21148
Resp. Party Other MSDS No.: 255; REVISION 004
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 11239
Box: 21148
Cage: EO264
Box: 21148
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: KNOWN HAZARDS: EYE AND SKIN IRRITATION. POSSIBLE
SENSITIZER. ACUTE: EYES: CAN CAUSE IRRITATION. SKIN: PROLONGED AND REPEATED
CONTACT CAN CAUSE IRRITATION. AN ALLERGIC SKIN REACTION (E.G., RASH, ITCHIN
G, REDDENING) CAN OCCUR WITH SOME INDIVIDUALS. INHALATION: POSSIBLE
IRRITATION. INGESTION: NONE EXPECTED. NOT CONSIDERED TO BE A ROUTE OF
EXPOSURE. EFFECTS OF INGESTION HAVE NOT BEEN DETERMINED. IARC CLASSIFIES
CRYSTALLINE SILICA (QUARTZ SAND) AS A GROUP 1 CARCINOGEN BASED UPON EVIDENCE
AMONG WORKERS IN INDUSTRIES WHERE THERE HAS BEEN LONG-TERM AND CHRONIC
EXPOSURE (VIA INHALATION) TO SILICA DUST, E.G. MINING, (EFFECTS OF
OVEREXPOSURE)
Explanation Of Carcinogenicity: SILICA, CRYSTALLINE-QUARTZ: IARC MONOGRAPHS,
SUPPLEMENT, VOLUME 68, PG 41, 1998: GROUP 1. NTP 8TH ANNUAL REPORT ON
CARCINOGENS, 1998: REASONABLY ANTICIPATED TO BE HUMAN CARCINOGEN. HUMAN:
LUNG.
Signs And Symptions Of Overexposure: HEALTH HAZARDS: QUARRY, STONE CRUSHING,
REFRACTORY BRICK AND POTTERY WORKERS. THIS PRODUCT DOES NOT POSE A DUST
HAZARD; THEREFORE, THIS CLASSIFICATION IS NOT RELEVANT.
Medical Cond Aggravated By Exposure: EYE, SKIN AND RESPIRATORY EXPECTED.
First Aid: EYES: FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. CALL A
PHYSICIAN. SKIN: WASH WITH SOAP AND WATER. INHALATION: MOVE VICTIM TO FRESH
AIR. CALL A PHYSICIAN IF SYMPTOMS PERSIST. INGESTION: SEEK MEDICAL
ATTENTION. DO NOT INDUCE VOMITING UNLESS DIRECTED TO BY A PHYSICIAN. NEVER
GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. OTHER: REFERRAL TO A
PHYSICIAN IS RECOMMENDED IF THERE IS ANY QUESTI ON ABOUT THE SERIOUSNESS OF
THE INJURY/EXPOSURE.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: TAKE UP WITH AN ABSORBENT MATERIAL AND PLACE IN A
CONTAINER FOR PROPER DISPOSAL. NOT CONSIDERED A HAZARDOUS WASTE ACCORDING TO
EPA DEFINITIONS.
Waste Disposal Methods: CONSULT WITH REGULATORY AGENCIES OR CORPORATE PERSONNEL
FOR DISPOSAL METHODS THAT COMPLY WITH LOCAL, STATE AND FEDERAL HEALTH AND
ENVIRONMENTAL REGULATIONS.
Handling And Storage Precautions: FOR INDUSTRIAL USE ONLY. KEEP AWAY FROM
CHILDREN. STORE IN A COOL, DRY AREA. STORE BETWEEN 40F AND 80F. USE WITH
ADEQUATE VENTILATION. AVOID PROLONGED OR REPEATED CONTACT.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point: >93.3C, 200.F
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER.
Fire Fighting Procedures: WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE KNOWN. THERMAL DECOMPOSITION PRODUCTS CAN
BE PRODUCED UNDER FIRE CONDITIONS. SEE REACTIVITY SECTION.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE NORMALLY REQUIRED. WHERE VENTILATION IS INADEQUATE
TO CONTROL VAPORS, USE A NIOSH-APPROVED RESPIRATOR WITH ORGANIC VAPOR
CARTRIDGES. NEVER ENTER A CONFINED SPACE WITHOUT AN APPROPRIATE NIOSH-APPR
OVED AIR SUPPLIED RESPIRATOR. IF DUSTS ARE GENERATED DURING DEMOLITION OR
REMOVAL, WEAR AN APPROPRIATE NIOSH-APPROVED DUST MASK OR RESPIRATOR.
Ventilation: GENERAL (I.E. NATURAL OR MECHANICALLY-INDUCED FRESH AIR
MOVEMENTS).
Other Protective Equipment: EMERGENCY EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: PRACTICE GOOD HYGIENE, I.E. WASH AFTER USING AND
BEFORE EATING OR SMOKING.
Supplemental Safety and Health: PHYSICAL/CHEMICAL PROPERTIES: VOC CONTENT: 0
G/L.
=======================================================
Physical/Chemical Properties
=======================================================
Boiling Point: =100.C, 212.F
Spec Gravity: 1.7
Solubility in Water: INSOLUBLE
Appearance and Odor: GRAY PASTE, WITH ESTER-LIKE ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: AVOID TEMPERATURE EXTREMES WHICH COULD SHORTEN
THE SHELF-LIFE OF THIS PRODUCT, I.E. BELOW FREEZING AND ABOVE 100F. (SEE
HANDLING AND STORAGE SECTIONS).
Materials To Avoid: STRONG ACIDS AND OXIDIZING AGENTS.
Hazardous Decomposition Products: THERMAL DECOMPOSITION CAN YIELD CARBON
MONOXIDE, CARBON DIOXIDE, NO*X, WATER.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: BENZOYL PEROXIDE WILL DECOMPOSE AT
TEMPERATURES GREATER THAN 150F.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
Transport Information: DOT SHIPPING NAME: NOT REGULATED.
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: SARA TITLE III, SECTION 313: THIS PRODUCT CONTAINS
5-10% BENZOYL PEROXIDE (CAS # 94-36-0) WHICH IS SUBJECT TO THE REPORTING
UNDER SECTION 313 OF SARA TITLE III (40 CFR PART 372).
Federal Regulatory Information: THIS MSDS HAS BEEN PREPATED IN ACCORDANCE WITH
THE FEDERAL OSHA HAZARD COMMUNICATION STANDARD. TSCA INVENTORY STATUS:
CHEMICAL COMPONENTS LISTED ON TSCA INVENTORY.
=======================================================
Other Information
=======================================================
Other Information: PRODUCT DESCRIPTION: METHACRYLATE RESIN AND HARDENER. PART A
IS IN THE LARGE TUBE; PART B IS IN THE SMALL ONE. CODES: HEALTH: 1;
FLAMMABILITY: 1; REACTIVITY: 1; PERSONAL PROTECTIVE EQUIPMENT: B.
HEALTH/SAFETY CONTACTS: STEVE GERRARD (X6309); JERRY METCALF (X6704).
=======================================================
HAZCOM Label
=======================================================
Product ID: HIT HY 150, PART A
Cage: 11239
Company Name: HILTI INC
Street: 5400 S 122ND E AVE
PO Box: 21148
Zipcode: 74121
Label Required IND: Y
Date Of Label Review: 10/06/1999
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Moderate
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE: EYES: CAN CAUSE IRRITATION. SKIN: PROLONGED
& REPEATED CONTACT CAN CAUSE IRRITATION. INHALATION: POSSIBLE IRRITANT.
CHRONIC: CANCER HAZARD. CONTAINS SILICA, CRYSTALLINE-QUARTZ WHICH IS LISTED
AS A HUMAN LUNG CARCINOGEN (FP N). SKIN: AN ALLERGIC SKIN REACTION (E.G.,
RASH, ITCHING, REDDENING) CAN OCCUR WITH SOME INDIVIDUALS. THIS PROD DOES
NOT POSE A DUST HAZARD. POSSIBLE SENSITIZER.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DEGLAZING SOLVENT,83-0-105532,83-9-105533
CAGE:09177
CAGE:1A714
CAGE:09177
CAGE:66172
============= Composition/Information on Ingredients =============
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 96%
Other REC Limits:NONE SPECIFIED
OSHA PEL:350 PPM/450 STEL
ACGIH TLV:350 PPM/450STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:OTHER COMPONENTS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS 10300 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: MILDLY
IRRITATING. WILL DEFAT SKIN. INHALATION: SLIGHTLY TOXIC, ANESTETHIC
EFFECTS MAY OCCUR IN RANGES OF 1000 PPM. INGESTION: NOT
SIGNIFICANTLY TOXIC.
Effects of Overexposure:EYES: IRRITATION. SKIN: IRRITATION, DEFATING.
INHALATION: ANESTHETIC EFFECTS. INGESTION: NOT SIGNIFICANTLY TOXIC.
Medical Cond Aggravated by Exposure:INCREASED SENSITIVITY TO ADRENALIN
MAY BE CAUSED BY OVEREXPOSURE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. SKIN: WASH AREA WITH
SOAP AND WATER. INHALATION: MOVE TO FRESH AIR. IF NOT BREATHING,
GIVE ARTIFICIAL RESPIRATION. IF BREATHING DIFFICULT GIVE OXYGEN.
GET MEDI CAL ATTENTION. INGESTION: DO NOT INDUCEVOMITING. GIVE MILK
OR USP MINERAL OIL.TAKE TO HOSPITAL EMERGENCY ROOM FOR FURTHER
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Lower Limits:7.0
Upper Limits:15.0
Extinguishing Media:WATER, DRY CHEMICAL OR CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SELF-CONTAINED
BREATHING APPARATUS FOR POSSIBLE EXPOSURE TO HYDROGEN CHLORIDE AND
TRACES OF PHOSGENE.
Unusual Fire/Explosion Hazard:VAPORS CONCENTRATED IN A CONFINED OR
POORLY VENTILATED AREAS CAN BE IGNITED ON CONTACT WITH A HIGH
ENERGY SPARK, FLAME OR HIGH INTENSITY SOURCE OF HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. CONTAIN FREE
LIQUID. ABSORB ON SUITABLE INERT ABSORBENT MATERIAL AND RECOVER FOR
PROPER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, WELL VENTILATED
AREA. DO NOT USE WITH ALUMINUM. KEEP AWAY FROM HEAT, OPEN FLAME AND
SPARKS. KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:PROTECT CONTAINERS FROM PHYSICAL DAMAGE. DO NOT REUSE
CONTAINER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC
VAPORS/MIST IF VAPOR CONCENTRATIONS ARE ABOVE TLV/PEL.
Ventilation:LOCAL EXHAUST TO MAINTAIN PEL/TLV (BELOW 50% OF TLV).
Other Protective Equipment:PROTECTIVE CLOTHING AND APRON TO PREVENT
ABSORPTION ON TO CLOTHING. PROVIDE EYE-WASH STATION AND SAFETY
SHOWER.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
THIS IS A NEW FORMULATION. OLD FORMULATION IS SHOWN ON PNI-A. NOTE THE
DIFFERENT INGREDIENTS BETWEEN PNI-A AND PNI-B.
================== Physical/Chemical Properties ==================
HCC:T4
Boiling Pt:B.P. Text:154F/68C
Vapor Pres:120 MMHG
Vapor Density:4.54
Spec Gravity:1.31
Evaporation Rate & Reference:0.35,(BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID WITH ETHEREAL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CAUSTICS, OXIDIZERS AND ALUMINUM.
Stability Condition to Avoid:OPEN FLAMES, HOT GLOWING SURFACES OR
ELECTRIC ARC.
Hazardous Decomposition Products:HYDROGEN CHLORIDE AND POSSIBLE TRACES
OF PHOSGENE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE MATERIAL IN ACCORDANCE WITH
LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ZYGLO PENETRANT ZL-27A
Preparer's Name:CHERI A. ZELEZNIK
CAGE:59042
CAGE:37676
CAGE:59042
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL, WHITE; (WHITE MINERAL OIL (PETROLEUM))
CAS:8042-47-5
RTECS #:PY8047000
Fraction by Wt: 30-60%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PHOSPHORIC ACID, ISODECYL DIPHENYL ESTER; (ISODECYL
DIPHENYL PHOSPHATE) LD50: (ORAL, RAT) 15.8 G/KG
CAS:29761-21-5
RTECS #:TC6180000
Fraction by Wt: 30-60%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CASTOR OIL
CAS:8001-79-4
RTECS #:FI4100000
Fraction by Wt: 10-30%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PROPANE, 2-METHYL-; (ISOBUTANE (PROPELLANT))
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 30%
OSHA PEL:1000 PPM (MFR)
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 2
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: CAN IRRITATE BY REMOVING NATURAL
SKIN OILS ON LONG OR REPEATED EXPOSURES. EYES: MAY CAUSE
IRRITATION. INHALATION: NOT SIGNIFICANT AT ROOM TEMPERATURES. WHEN
HEATED OR SPRAYED, PRODUCT VAPORS MAY CAUSE DIZZINESS & NAUSEA.
INGESTTION: NOT SIGNIFICANT IN SMALL (MOUTHFUL) AMOUNTS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:SKIN: WASH OFF W/SOAP & WATER. USE SOOTHING LOTION. EYES:
RINSE CAREFULLY UNDER UPPER & LOWER EYELIDS USING PLENTY OF WATER
FOR AT LEAST 15 MIN. INHAL: REMOVE TO FRESH AIR IF DIZZY/NAUS.
INGEST: DO NO T INDUCE VOMIT. ACCIDENTAL INGEST OF SMMOUTHFUL IS
NOT EXPECTED TO CAUSE SIGNIFICANT HARM. NOTE: IN ALL SEV CASES,
REGIONAL POIS CTL CTR.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:200F,93C
Lower Limits:1%
Upper Limits:6%
Extinguishing Media:CARBON DIOXIDE, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
KEEP CNTNRS COOL W/WATER SPRAY. DO NOT SPRAY WATER DIRECTLY ON
BURNING PROD. IT MAY FLOAT & SPREAD THE FIRE.
Unusual Fire/Explosion Hazard:AEROSOL CANS MAY BURST AT TEMPERATURES
OVER 130F(54C) & SPRAY CONTENTS INTO FIRE. HAZARDOUS COMBUSTION
PRODUCTS: SMOKE, SOOT, OXIDES OF CARBON & NITROGEN.
================== Accidental Release Measures ==================
Spill Release Procedures:MOP UP OR SWEEP UP WITH ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING SPRAY MIST. AVOID EYE
CONTACT. AVOID REPEATED OR PROLONGED SKIN CONTACT. STORE AWAY FROM
HEAT SOURCE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR WITH FILTER IF
SPRAYED IN ENCLOSED, UNVENTILATED SPACE.
Ventilation:NONE, UNLESS APPLIED AS SPRAY. USE WHERE VENTILATION WILL
CARRY SPRAY MIST AWAY FROM OCCUPIED AREAS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
VP: BULK:<0.10; AEROSOL: 60 PSI @ 75F. % VOLAT: NONE (30% IN AEROSOL).
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:455F,235C
Vapor Pres:SUPDAT
Vapor Density:HVR/AIR
Spec Gravity:0.96
pH:NEUT
Evaporation Rate & Reference:NEGLIGIBLE
Solubility in Water:0%
Appearance and Odor:GREEN OILY LIQUID; MILD ODOR.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:SOOT, OXIDES OF CARBON IF HEATED TO
COMBUSTION TEMPERATURES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS . AS A NON-HAZARDOUS OILY WASTE,
INCINERATE OR SEND TO WASTE HANDLER WHO CAN BLEND IT INTO SECONDARY
FUELS. EMPTY AEROSOL CANS BEFORE DISPOSAL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:COLD SHOT REFRIGERANT 12 (AEROSOL)
Preparer's Name:I. LIEBMAN
CAGE:77628
CAGE:77628
============= Composition/Information on Ingredients =============
Ingred Name:DICHLORODIFLUOROMETHANE (SARA III)
CAS:75-71-8
RTECS #:PA8200000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9394
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD 50 ORAL RAT IS > 1000 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HEALTH HAZARDS: ACUTE: MAY CAUSE
ASPHYXIATION BY REDUCING OXYGEN AVAILABLE FOR BREATHING. DEATH CAN
OCCUR WITHOUT WARNING. LIQUID IS AN IRRITANT AND CAN CAN CAUSE
FROSBITE. CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NONE OF THE INGREDIENTS IN THIS PRODUCT
IS LISTED BY NTP, IARC OR OSHA AS A CARCINOGEN.
Effects of Overexposure:LIQUID CAN CAUSE FROSTBITE. VAPOR CAN CAUSE
LIGHTHEADEDNESS, GIDDINESS, SHORTNESS OF BREATH, AND MAY LEAD TO
NARCOSIS, CARDIAC IRREGULARITIES, UNCONSCIOUSNESS OR DEATH.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH A HISTORY OF
CARDIOVASCULAR DISORDERS MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.SEE
DOCTOR. SKIN:WASH WITH LUKEWARM,SOAPY WATER.TREAT FOR FROSTBITE.
INHALATION:REMOVE VICTIM TO FRESH AIR.GIVE OXYGEN/CPR IF NEEDED.SEE
DOCTOR. DO NOT GIVE EPINEPHRINE OR SIMILAR DRUGS. NOTE TO
PHYSICIAN: BECAUSE OF INCREASED RISK OF CARDIAC
DYSRYTHMIAS,CATECHOLAMINE DRUGS,SUCH AS EPINEPHRINE SHOULD BE
CONSIDERED ONLY AS A LAST RESORT.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.CONTAINERS MAY BURST
FROM HEAT OF FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE PERSONNEL. REMOVE OPEN FLAMES.
VENTILATE AREA, ESPECIALLY LOW PLACES WHERE HEAVY VAPORS MIGHT
COLLECT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE, HEAT, IGNITION SOURCES. DO NOT
HEAT ABOVE 125F.
Other Precautions:AVOID EYE AND SKIN CONTACT. DO NOT BREATHE
VAPORS.AVOID CONTACT WITH OXIDIZING AGENTS AND ALKALINE METALS.DO
NOT WEAR CONTACT LENSES.DISPOSE OF PRESSURIZED CONTAINER PROPERLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. NIOSH/MSHA-APPROVED
SELF-CONTAINED BREATHING APPARATUS WHEN TESTING THIS PRODUCT.
Ventilation:NO SPECIAL REQUIREMENTS. USE GENERAL (MECHANICAL)
VENTILATION IN LOW PLACES. USE LOCAL EXHAUST FOR LARGE RELEASE.
Other Protective Equipment:PROTECTIVE CLOTHING AS REQUIRED TO MINIMIZE
EXPOSURE FROM PROLONGED OR REPEATED CONTACT. EYE BATH AND SAFETY
SHOWER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NONE.
================== Physical/Chemical Properties ==================
HCC:G3
Boiling Pt:B.P. Text:-22F,-30C
Vapor Pres:AEROSOL
Spec Gravity:1.31
Solubility in Water:INSOLUBLE
Appearance and Odor:AEROSOL.LIQUID IS PALE WITH ETHEREAL ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS,ALKALINE METALS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:CO,CO*2,HYDROCHLORIC ACID,
HYDROFLUORIC ACID, POSSIBLE CARBONYL HALIDES,SULFUR
OXIDES,ALDEHYDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.
RECLAIM BY DISTILLATION OR REMOVE TO A PERMITTED WASTE DISPOSAL
FACILITY. DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE AND
LOCAL REGULATIONS. EPA HAZARDOU S WASTE NUMBER UO75.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:AUTOCLEAR ULTRA LV HARDENER 004002
CAGE:AKZNB
CAGE:AKZNB
============= Composition/Information on Ingredients =============
Ingred Name:ACETIC ACID, BUTYL ESTER; (N-BUTYL ACETATE) (CERCLA)
VP:8.0; LD50(ORAL):14000; LEL:1.7%
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 10-20%
OSHA PEL:150 PPM
ACGIH TLV:150 PPM/200STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOCYANIC ACID, HEXAMETHYLENE ESTER, POLYMERS;
(POLYHEXAMETHYLENE DIISOCYANATE)
CAS:28182-81-2
RTECS #:NQ9170000
Fraction by Wt: >80%
OSHA PEL:N/K
ACGIH TLV:0.5 MG/M3 (MFR)
Ingred Name:HEXANE, 1,6-DIISOCYANATO-; (HEXAMETHYLENE DIISOCYANATE
MONOMER) LD50(ORAL):710
CAS:822-06-0
RTECS #:MO1740000
Fraction by Wt: 0.26%
OSHA PEL:N/K
ACGIH TLV:0.005 MG/M3 (MFR)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:EFTS OF OVEREXP:HAS BEEN KNOWN TO OCCAS CAUSE BURNING
SENSATION IN SHORT TERM. (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:EYE:DMG. INGEST:KIDNEY & BLOOD SYS DMG. OTHER HLTH
EFTS:INTENTIONAL MISUSE BY DELIB CONCS & INHAL (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:CONTENTS MAY BE HARMFUL/FATAL. RPTS HAVE ASSOC RPTD &
PRLNGD OCCUP OVEREXP TO SOLVS W/PERM BRAIN & NERV (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:SYS DMG. AROMATIC HYDROCARBONS HAVE BEEN SHOWN IN
ANIMAL STUDIES TO CAUSE ADVERSE EFTS ON BLOOD & BLOOD (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:FORMING TISSUE AND MAY IN RARE CASES SENSITIZE HEART
CAUSING CARDIAC ARRHYTHMIA.
RTECS #:9999999ZZ
Ingred Name:VENT:DURING HEATING. REMOVE DECOMP PRODS FORMED DURING
WELDING/FLAME CUTTING ON SURFS COATED W/PROD.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:NASAL & RESP IRRIT, DIZZ,
WEAK, FATG, NAUS, HDCH, POSS UNCONS, CHEM PNEUM, CNS DEPRESS & EVEN
ASPHY. SKIN:EXTRACTION OF NATURAL OILS W/RSLTING DRY SKIN, IRRIT,
REDNESS & DERM. EYE:IRRIT, R EDNESS, PAIN, BLURRED VISION,
SENSATIONOF SEEING HALOS AROUND LIGHTS. WHEN MIXED W/PROPER
COMPONENTS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:& SPRAYED PROD HAS BEEN KNOWN TO
OCCAS CAUSE PAIN IN SHORT TERM. INGEST:GI IRRIT, NAUS, VOMIT &
DIARR. CHRONIC:INHAL:DELAYED LUNG DMG, KIDNEY, LIVER & CARDIAC
DISORDERS, RED BLOOD CELL & LEU KOCYTE DISORDERS WHICH MAY RSLT IN
ANEMIA. SKIN:SENSIT MAY OCCUR. WHEN MIXED W/PROPER COMPONENTS &
SPRAYED PROD (ING 4)
Medical Cond Aggravated by Exposure:ISOCYANATE SENSITIZATION, SKIN
DISORDERS, EYE DISORDERS.
======================= First Aid Measures =======================
First Aid:INHALATION:MOVE TO FRESH AIR, GIVE ARTIFICIAL RESPIRATION IF
NECESSARY. SKIN CONTACT:WASH WITH SOAP AND WATER, NOT SOLVENT. EYE
CONTACT:FLUSH WITH WATER FOR AT LEAST 15 MINUTES, CONSULT A
PHYSICIAN. I NGESTION:DRINK ONE OR TWO GLASSES OF WATER TO DILUTE.
DO NOT INDUCE VOMITING. CONSULT A PHYSICIAN OR POISON CONTROL
CENTER IMMEDIATELY. TREAT SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point:78.0F,25.6C
Lower Limits:1.7%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICALS.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER SHOULD BE USED TO COOL CONTAINERS EXPOSED TO
FIRE.
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD, ISOLATE FROM
HEAT, ELEC EQUIP, SPKS & OPEN FLAMES. CLSD CNTNRS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. APPLICATN TO HOT (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
BREATHING VAPORS, VENTILATE CONFINED AREA. DIKE TO REDUCE EXTENT OF
SPILL. REMOVE WITH INERT ABSORBENT USING NON-SPARKING TOOLS. IF
NECESSARY, REPORT TO APPLICABL E GOVERNMENT AGENCY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE CNTNRS OUT OF SUN & AWAY FROM
HEAT, SPKS, & OPEN FLAMES. CLOSE ALL CNTNRS AFTER EACH USE. CONSULT
NFPA & LOC CODES FOR ADDNL STOR REQS.
Other Precautions:USE APPRVD BONDING & GROUNDING PROCEDURES. OBSERVE
LBL PRECS. KEEP CLOSURES TIGHT & CNTNR UPRIGHT TO PVNT LEAKAGE.
AVOID BRTHG SANDING DUST. DO NOT WELD/FLAME CUT ON EMPTY DRUM. WHEN
SPRAYING PROD USE MAX PERS PROT EQUIP; COVER ALL (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ADEQ VENT IS REQD. PROD CNTNS ISOCYANATES. USE
NIOSH APPRVD POS PRESS AIR SUPPLY RESP. SEE SFTY EQUIP SUPP FOR
EVAL & REC. IN CASES WHERE NO MONITORING FOR AIRBORNE CONTAMS HAS
BEEN CARRIED OUT, ASSUM E MAX EXPOS & USE PAINT SUIT, (SUPDAT)
Ventilation:PROVIDE SUFFICIENT VENT TO KEEP VAP CONCS BELOW GIVEN TLV
&/OR PEL. FOR BAKING ASHES, EXHST VAPS EMITTED (ING 9)
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
USE CHEM RESIST APRON, BOOTS/OTHER CLTHG IF NEEDED.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING OR USING THE
WASHROOM. LAUNDER CLOTHING BEFORE REUSE.
Supplemental Safety and Health
EXPLO HAZS:SURFS REQS SPECIAL PRECS. DURING EMER CNTNRS, OVEREXP TO
DECOMP PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE IMMED APPARENT.
GET MED ATTN. OTHER PRECS:EXPOSED AREAS. LIQ MAY PENETRATE SHOES &
APPROVED RESP EQUIP.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>252F,>122C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.07
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:CLEAR LIQUID; ORGANIC ODOR.
Percent Volatiles by Volume:22.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALIS, OXIDIZERS, ALKALI METALS, WATER, AMINES, NITRIC ACID, SODIUM
HYPOCHLORITE, METAL COMPOUNDS.
Stability Condition to Avoid:OPEN FLAME, HEAT, SPARKS, MOISTURE.
Hazardous Decomposition Products:OXIDES OF CARBON & NITROGEN, VARIOUS
HYDROCARBONS, HYDROGEN CYANIDE, HEXAMETHYLENE DIISOCYANATE (HDI).
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE OR PROVINCIAL
AND LOCAL POLLUTION REQUIREMENTS. IN ADDITION, RAGS, SPRAY BOOTH
FILTERS, PAINT SUITS, EMPTY CANS, ETC, CONTAM W/PROD MAY BE HAZ
WASTE. DETERM WHETHER CON TAM ITEMS ARE HAZ & DISP OF AS APPROP.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:METCO 67F-NS
CAGE:FO876
CAGE:FO876
CAGE:39918
============= Composition/Information on Ingredients =============
Ingred Name:CHROMIUM (SARA III)
CAS:7440-47-3
RTECS #:GB4200000
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9293
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: IRRITATION,
SENSITIVE & DERMATITIS. INHALATION: LUNG HISTOLOGIC FIBROSIS,
ASTHMA ALLERGIC, NASAL CAVITY & RESPIRATORY SYSTEM IRRITATION.
Explanation of Carcinogenicity:NICKEL IS A SUSPECTED HUMAN A1
CARCINOGEN BY ACGIH. CHROMIUM IS AN A2 CARCINOGEN.
Effects of Overexposure:EYES: IRRITATION. SKIN: IRRITATION, SENSITIVE,
& DERMATITIS. INHALATION: LUNG HISTOLOGIC FIBROSIS, ASTHMA
ALLERGIC, NASAL CAVITY, RESPIRATORY SYSTEM IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER. SKIN: WASH W/SOAP & WATER. INHALATION:
REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE CLASS D FIRE EXTINGUISHER
Fire Fighting Procedures:TREAT AS A METALLIC FIRE.
Unusual Fire/Explosion Hazard:MODERATE FIRE HAZARD IN THE FORM OF DUST
WHEN EXPOSED TO FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:SPILLED MATERIAL MAY BECOME AIRBORNE. GOOD
HOUSEKEEPING BY SWEEPING THE AREA CLEAN IS NECESSARY TO REMOVE
THESE MATERIALS FROM BECOMING A SOURCE OF AIR CONTAMINATION.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID EXCESSIVE SKIN CONTACT & ORAL
INGESTION. DON'T PERMIT SPRAY DUST TO ENTER EYES, MOUTH, CUTS,
SCRATCHES OR OPEN WOUNDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH APPROVED RESPIRATOR FOR DUST, FUMES,
MISTS DURING THERMAL SPRAY PROCESS.
Ventilation:EQUIPMENT DESIGNED TO CREATE AN AIR VELOCITY OF 200 FPM.
Other Protective Equipment:EYE WASH STATION, EAR PROTECTION & FULL
PROTECTIVE EQUIPMENT, & ALUMINIZED APRON.
Supplemental Safety and Health
SPRAYING UP TO 40 KW- SHADE 9, 40 TO 60 KW- SHADE 10 & >60 KW-SHADE
11.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:2200-2900F
Spec Gravity:4.5
Solubility in Water:NEGLIGIBLE
Appearance and Odor:POWDER W/NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:OZONE, NITRIC OXIDE FROM PLASMA FLAME.
CHLORINATED HYDROCARBON VAPORS NEAR PLASMA FLAME MAY DECOMPOSE TO
PHOSGENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: DURALCO 122
Cage: 3R434
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 3R434
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHAL:MIST OR VAPOR CAN IRRITATE THE NOSE AND THROAT.
EYE:SUBSTANTIALLY IRRITATING TO EYES. SKIN:SUBSTANCE IS MODERATELY IRRITATING
AND CAN CAUSE SUPERFICIAL BURNS AFTER PROLONGED CONTACT. NOT ABSORBE D IN
TOXIC AMOUNTS. INGEST:POSSIBLY HARMFUL IF SWALLOWED. DELAYED EFTS:PRLNGD/RPTD
EXPOS CAN CAUSE ALLERGIC REACTION.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL: MOVE TO FRESH AIR. GIVE ARTF RESP IF BRTHG HAS STOPPED.
EYE:FLUSH W/LARGE AMT OF WATER FOR AT LST 15 MIN. GET PROMPT MED ATTN.
SKIN:WASH THORO W/SOAP & WATER. REMOVE & WASH CLTHG BEFORE REUSE.
INGEST:DILUTE BY GIVING 2 GLASSES OF WATER TO DRINK. SEE MD. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCON PERSON. NOTE TO MD:ALLERGIC DERM/RESP RESPONSE
IN SUSCEPTIBLE INDIVIDUALS MAY BE DELAYED (SUPDAT)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: DIKE & ABSORB SPILL ON INERT MATL (SAND, EARTH,
ETC.). TRANSFER DIKING MATL TO CNTNRS FOR DISP. WEAR PROT CLTHG. USE BRTHG
APPAR (NIOSH/MSHA-APPRVD, PRESS-DEMAND, SELF-CNTND)/AIR MASK FOR LG SPILLS IN
CONFINED AREA. WASH CLTHG BEFORE REUSE. (SUP DAT)
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: INCINERATE LIQUID IN APPROVED EQUIPMENT. LANDFILL OR
INCINERATE CONTAMINATED DIKING MATERIAL IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
Handling And Storage Precautions: STORE AWAY FROM EXCESSIVE HEAT (E.G.,
STEAMPIPES, RADIATORS), FROM SOURCES OF IGNITION AND FROM REACTIVE MATERIALS.
DO NOT STORE NEAR FOOD OR FEED.
Other Precautions: CORROSIVE TO COPPER AND BRASS ON LONG STORAGE. AVOID ALL EYE
AND SKIN CONTACT. THE USE OF THIS AUXILARY MATERIALS SHOULD BE CONFINED TO
DESIGNATED WORK AREAS. EMPTIED CONTAINERS MAY STILL CONTAIN HAZA RDOUS
RESIDUES.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: >295F,>146C
Extinguishing Media: FOAM, CO*2, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE REQUIRED IF GOOD VENTILATION IS MAINTAINED. WEAR
NIOSH/MSHA APPROVED (OR EQUIVALENT) RESPIRATOR SUITABLE FOR CONCENTRATIONS
AND TYPES OF AIR CONTAMINANTS ENCOUNTERED.
Ventilation: NORMAL ROOM VENTILATION.
Other Protective Equipment: EMERG EYE WASH AND DELUGE SHOWER WHICH MEETS ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: FIRST AID PROC:EVEN WEEKS/MONTHS AFTER FREQUENT
&/OR PRLNGD CONT. ACUTE EFTS CAN INCLUDE MUCOSAL DMG, SEV LARYNGEAL
EDEMA, & SHOCK ASSOC W/CORR AGENTS. POSS MUCOSAL DMG MAY CONTRAINDICATE
THE USE OF G ASTRIC LAVAGE. SPILL PROC:DESTROY CLTHGTHAT CANNOT BE DECONTAM
(I.E. SHOES). EYE PROT:OR APPROVED EQUIVALENT.
=======================================================
Physical/Chemical Properties
=======================================================
Vapor Density: >1
Spec Gravity: 1.16 (H*2O=1)
Solubility in Water: NEGLIGIBLE
Appearance and Odor: AMBER TRANSPARENT LIQUID TO VISCOUS BLACK LIQUID.
Percent Volatiles by Volume: NEG
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products: NONE SPECIFIED BY MANUFACTURER.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: DURALCO 122
Cage: 3R434
Company Name: COTRONICS CORP
Street: 3379 SHORE PARKWAY
Zipcode: 11235
Label Required IND: Y
Date Of Label Review: 12/12/1994
Status Code: C
Label Date: 12/12/1994
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. INHAL:MIST OR VAPOR CAN IRRITATE THE NOSE
AND THROAT. EYE:SUBSTANTIALLY IRRITATING TO EYES. SKIN:SUBSTANCE IS
MODERATELY IRRITATING AND CAN CAUSE SUPERFICIAL BURNS AFTER PROLONGED CONTACT
. NOT ABSORBED IN TOXIC AMOUNTS. INGEST:POSSIBLY HARMFUL IF SWALLOWED.
CHRONIC:PRLNGD/RPTD EXPOS CAN CAUSE ALLERGIC REACTION.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:741036 BROWN 3279
CAGE:61196
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL SPIRITS
CAS:64475-85-0
RTECS #:PY8240000
Fraction by Wt: 35%
ACGIH TLV:500 PPM
Ingred Name:TRIETHYLAMINE (SARA III)
CAS:121-44-8
RTECS #:YE0175000
Fraction by Wt: <0.5%
OSHA PEL:25 PPM/15 STEL
ACGIH TLV:10 PPM/15 STEL; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:INHALATION-ANESTHETIC,IRRITATION OF RESPIRATORY
TRACT OR ACUTE NERVOUS SYSTEM DEPRESSION.
======================= First Aid Measures =======================
First Aid:CONTACT-FLUSH SKIN AND EYES WITH WATER WHILE REMOVING
CONTAMINATED CLOTHING. INHALATION-REMOVE TO FRESH AIR. CALL
PHYSICIAN IF SYMPTOMS PERSIST.
===================== Fire Fighting Measures =====================
Flash Point:104F, 40C TCC
Lower Limits:1.10
Extinguishing Media:NFPA CLASS B EXTINGUISHER; POLYMER FOAM FOR LARGE
FIRES
Fire Fighting Procedures:SELF CONTAINED BREATHING APPARATUS SHOULD BE
AVAILABLE
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
BREATHING VAPORS. VENTILATE AREA. REMOVE WITH INERT ABSORBENT AND
NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F STORE LARGE
QUANTITIES IN BUILDING DESIGNED TO COMPLY WITH OSHA 1910.106
Other Precautions:GROUND CONTAINERS WHEN POURING.AVOID FREE FALL OF
LIQUID IN XS OF FEW INCHES DO NOT FLAME CUT, BRAZE OR WELD COATED
MATERIAL WITHOUT BUR OF MINES APPROVED RESPIRATOR OR APPROPRIATE
VENTILATION
============= Exposure Controls/Personal Protection =============
Respiratory Protection:OPEN AREA:BUR MINES MECH RESPIRATOR;CLOSED:BUR
MINES CHEM/MECH FILTE
Ventilation:GENERAL DILUTION OR LOCAL EXHAUST TO KEEP TLV BELOW LIMIT
Other Protective Equipment:PREVENT PROLONGED SKIN CONTACT TO
CONTAMINATED CLOTHING
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:311-373F
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:59
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS-INCINERATE IN APPROVED FACILITY-DO NOT
INCINERATE CLOSED CONTAINERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:V-21 METALLO ORGANIC STANDARD
CAGE:0RP29
CAGE:0RP29
============= Composition/Information on Ingredients =============
Ingred Name:SILVER*96-2*
CAS:7440-22-4
RTECS #:VW3500000
OSHA PEL:0.01 MG/CUM
ACGIH TLV:0.1 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ALUMINUM*96-2*
CAS:7429-90-5
RTECS #:BD0330000
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:BORON *96-2*
CAS:7440-42-8
RTECS #:ED7350000
Ingred Name:BARIUM *96-2*
CAS:7440-39-3
RTECS #:CQ8370000
OSHA PEL:0.5 MG/CUM
ACGIH TLV:0.5 MG/CUM
Ingred Name:CALCIUM
CAS:7440-70-2
RTECS #:EV8040000
Ingred Name:CADMIUM (SUSPECTED HUMAN CARCINOGEN BY IARC, SUPSECTED
CARCINOGEN BY NTP, IARC - GROUP 1)*96-2*
CAS:7440-43-9
RTECS #:EU9800000
Other REC Limits:A2 CARCINOGEN
OSHA PEL:0.05 MG/CUM (CD)
ACGIH TLV:0.01 MG/CUM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:CHROMIUM METAL, CHROMIUM, CHROME (KNOWN CARCINOGEN BY NTP;
IARC CARC - GROUP 3) *96-2*
CAS:7440-47-3
RTECS #:GB4200000
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:COPPER (DUST & MIST), BRONZE POWDER *96-2*
CAS:7440-50-8
RTECS #:GL5325000
Other REC Limits:1 MG(CU)/M3 (DUST)
OSHA PEL:0.1 MG(CU)/M3 (FUME)
ACGIH TLV:0.2 MG/M3 (FUME)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:IRON *96-2*
CAS:7439-89-6
RTECS #:NO4565500
Ingred Name:MAGNESIUM
CAS:7439-95-4
RTECS #:OM2100000
Ingred Name:MANGANESE *96-2*
CAS:7439-96-5
RTECS #:OO9275000
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM (DUST)
Ingred Name:MOLYBDENUM (SOLUBLE COMPOUND)
CAS:7439-98-7
RTECS #:QA4680000
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:SODIUM
CAS:15307-79-6
RTECS #:AG6310000
Ingred Name:NICKEL (SUSPECTED ANIMAL/HUMAN CARCINOGEN BY IARC GROUP 2B,
SUSPECTED CARCINOGEN BY NTP) *96-2*
CAS:7440-02-0
RTECS #:QR5950000
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/CUM
ACGIH TLV:0.05 MG/CUM IC
Ingred Name:PHOSPHORUS (YELLOW & WHITE)
CAS:7723-14-0
RTECS #:TH3500000
Other REC Limits:100 UG/CUM
OSHA PEL:0.1 MG/CUM
ACGIH TLV:0.1 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:LEAD, INORGANIC LEAD (IARC CARC GROUP 2B) *96-2*
CAS:7439-92-1
RTECS #:OF7525000
ACGIH TLV:0.15 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
ACGIH TLV:10 MG/CUM
Ingred Name:TIN *96-2*
CAS:7440-31-5
RTECS #:XP7320000
OSHA PEL:2 MG/CUM
ACGIH TLV:2.0 MG/CUM
Ingred Name:TITANIUM, DRY POWD *96-2*
CAS:7440-32-6
RTECS #:XR1700000
Ingred Name:VANADIUM
CAS:1314-62-1
RTECS #:YW1355000
OSHA PEL:0.5 MG/CUM
ACGIH TLV:0.05 MG/CUM (DUST)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ZINC
CAS:7440-66-6
RTECS #:ZG8600000
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:OIL PETROLEUM DISTILLATES, SOLVENT-DEWAXED HEAVY PARAFFINIC
CAS:64742-65-0
RTECS #:PY8038500
Fraction by Wt: 99%
Other REC Limits:5 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SKIN: PROLONGED/REPEATED EXPOSURE MAY
CAUSE MINOR IRRITATION. PRODUCT CAN CAUSE SEVERE INJURY & EVEN
DEATH.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/PLENTY OF WATER FOR 15 MINS. SKIN:
WASH THOROUGHLY W/SOAP & WATER. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>450F
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, FOAM/CO2.
Fire Fighting Procedures:WATER/FOAM MAY CAUSE FROTHING. USE WATER TO
KEEP CONTAINERS COOL. WATER SPRAY MAY BE USED TO FLUSH SPILLS AWAY
& TO DILUTE NONCOMBUSTIBLE MIXTURES.
Unusual Fire/Explosion Hazard:PRODUCTS OF COMBUSTION MAY CONTAIN CO,
CO2 & OTHER TOXIC MATERIALS. DON'T ENTER ENCLOSED/CONFINED SPACE
W/O PROPER PROTECTIVE EQUIPMENT & RESPIRATORY PROTECTION
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP ANY MATERIALS & FOLLOW RECOMMENDED
DISPOSAL PROCEDURES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN ORIGINAL CONTAINER USED FOR
SHIPMENT & KEEP TIGHTLY SEALED WHILE NOT IN USE.
Other Precautions:AVOID CONTACT W/MATERIAL/BREATHING CHEMICAL
VAPORS/FUMES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE PROTECTIVE RESPIRATORS.
Other Protective Equipment:PROTECTIVE CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>600F
Spec Gravity:0.6-0.9
Evaporation Rate & Reference:(ETHER = 1): <0.1
Solubility in Water:INSOLUBLE
Appearance and Odor:LIGHT OILY LIQUID; NONDESCRIPTIVE ODOR
Percent Volatiles by Volume:<0.1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIALS, INCOMPLETE COMBUSTION, ORGANIC METALS.
Stability Condition to Avoid:HEAT, FLAME
Hazardous Decomposition Products:COMBUSTION: CO2, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. CLASS III B COMBUSTIBLE LIQUIDS PER NFPA.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MICROPRT 03, 2559879-0001 MICROLASER PRINTER TONER
Kit Part:Y
CAGE:01277
CAGE:01277
CAGE:06668
============= Composition/Information on Ingredients =============
Ingred Name:MAGNATITE
Fraction by Wt: 32%
Other REC Limits:NONE RECOMMENDED
Ingred Name:STYRENE ACRYLATE COPLOYMER
Fraction by Wt: 63.5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYPREPYLENE
Fraction by Wt: 3.5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:METAL COMPLEX OF AZO COMPOUND
Fraction by Wt: 1.0%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL) > 5 GM/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY CAUSE IRRITATION OF SKIN,
EYES AND MUCOUS MEMBRANES. CHRONIC: NO LONG TERM EFFECTS ARE KNOWN
FOR THIS PRODUCT.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:INHALATION-RESPIRATORY TRACT IRRITATION MAY
OCCUR. SKIN-NOT EXPECTED TO BE IRRITATING TO SKIN. EYE-IF PRODUCT
COMES IN CONTACT WITH THE EYE, IT MAY CAUSE IRRITATION.
INGESTION-IN NORMAL USE, INGESTIONIS UNLIKELY, BUT IF INGESTED,
IT MAY IRRITATE THE GASTROINTESTINAL TRACT.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/DIRECTED STREAM OF WATER FOR @
LEAST 15 MIN WHILE FORCIBLY HOLDING EYELIDS APART TO ENSURE
COMPLETE IRRIGATION OF EYE. GET MED ATTN IF NEEDED. SKIN: WASH
THOROUGHLY W/SOAP & WATER. INHALE: REMOVE FROM EXPOSURE.
IFBREATHING DIFFICULT/OTHER GET MED ATTN. INGEST: DILUTE BY
DRINKING LARGE QUANTY WATER; IF VOMIT OCCURS, ADMINISTER MORE
WATER. GET MED ATTN IF NEEDED.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, FOAM, DRY CHEMICAL OR CARBON DIOXIDE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP OR SWEEP UP AND STORE PROPERLY OR
DISPOSE OF IN ACCORDANCE WITH ALL LEGAL REQUIREMENTS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN ORIGINAL CONTAINER. STORE IN
COOL, DRY PLACE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NECESSARY. MINIMIZE INHALATION OF DUST.
Ventilation:NO SPECIAL REQUIREMENTS.
Other Protective Equipment:NOT NECESSARY.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING IF ANY MATERIAL
GETS ON SKIN.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.47 (H2O=1)
Solubility in Water:INSOLUBLE; < 0.1%
Appearance and Odor:FINE BLACK POWDER; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:MAY INCLUDE CARBON MONOXIDE, CARBON
DIOXIDE AND OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:NO SPECIAL TECHNIQUES BEYOND NORMAL PRACTICE.
INSURE CONFORMITY WITH FEDERAL, STATE AND LOCAL REGULATIONS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:LD-301 LYSOL BRAND FOAMING BASIN TUB & TILE CLEANER
CAGE:DO879
CAGE:DO879
CAGE:73820
============= Composition/Information on Ingredients =============
Ingred Name:2-(2-BUTOXYETHYOXY)-ETHANOL, DIETHYLENE GLYCOL MONOBUTYL
ETHER (BUTYL CARBITOL)
CAS:112-34-5
RTECS #:KJ9100000
Fraction by Wt: 5.6%
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 7%
Other REC Limits:1000 PPM
OSHA PEL:1800 MG/CUM
ACGIH TLV:1000 PPM
Ingred Name:DIOCTYL DIMETHYL AMMONIUM CHLORIDE
Fraction by Wt: 0.025%
Ingred Name:OCTYL DECYL DIMETHYL AMMONIUM CHLORIDE
CAS:32426-11-2
RTECS #:HD6520000
Fraction by Wt: 0.025%
Ingred Name:OCTYL DECYL DIMETHYL AMMONIUM CHLORIDE
Fraction by Wt: 0.025%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION. INGESTION:
GASTROINTESTINAL TRACT IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES/SKIN: IRRITATION. INGESTION:
GASTROINTESTINAL TRACT IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS. REMOVE
CONTACT LENSES TO INSURE A THOROUGH FLUSH. SKIN: RINSE W/WATER.
INGESTION: GIVE LARGE QUANTITIES OF WATER TO DILUTE. DON'T GIVE
LIQUIDS TO AN UNCONSCIOUS PERSON. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>200F
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEMICAL OR CO.
Fire Fighting Procedures:USE SCBA & FLAME/CHEMICAL RESISTANT CLOTHING.
IF W/O RISK, REMOVE MATERIAL FROM FIRE AREA. USE WATER SPRAY TO
COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:EXPOSURE TO TEMP. >120F OR IN SUN,
DISCARDING CAN IN FIRE OR INCINERATOR MAY CAUSE BURSTING.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH SPILLS W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE <120F COOL, DRY LOCATION AWAY
FROM DIRECT SUNLIGHT, HOT SURFACES, SPARKS OR FLAME. DON'T
PUNCTURE, INCINERATE OR USE NEAR HEAT OR FLAME.
Other Precautions:THIS PRODUCT IS A REGISTERED PESTICIDE. USE OF THIS
PRODUCT IN A MANNER NOT CONSISTENT W/THE LABEL INSTRUCTIONS IS A
VIOLATION OF FEDERAL LAW.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS REQUIRED.
Ventilation:AS REQUIRED.
Other Protective Equipment:AS REQUIRED.
Supplemental Safety and Health
CHEMICALS OF THIS PRODUCT ARE IDENTIFIED AS A SARA SECTION 313 TOXIC
CHEMICAL.
================== Physical/Chemical Properties ==================
Vapor Pres:34-40 PSIG
Vapor Density:>AIR
Spec Gravity:1.007-1.017
pH:12.1
Evaporation Rate & Reference:SLOWER THAN BU AC
Solubility in Water:MISCIBLE
Appearance and Odor:AEROSOL CONTAINER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS & ACIDS
Stability Condition to Avoid:HEAT, OPEN FLAME, SUN, FIRE, TEMPS. >120F
Hazardous Decomposition Products:OXIDES OF NITROGEN, CO & OTHER
UNIDENTIFIED ORGANIC COMPOUNDS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:GENESOLV D SOLVENT (FREON 113)
CAGE:OLYW2
CAGE:OLYW2
CAGE:1L164
============= Composition/Information on Ingredients =============
Ingred Name:1,1,2-TRICHLORO-1,2,2-TRIFLUOROETHANE (FREON 113) (SARA
III)
CAS:76-13-1
RTECS #:KJ4000000
Fraction by Wt: 100%
OSHA PEL:1000PPM/1250STEL
ACGIH TLV:1000PPM/1250STEL9192
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
Effects of Overexposure:ASPHYXIATION,DROW,IRRIT
THROAT,DERM,INCO,EXCITEMENT,ARRHY,MILD EYE & SKIN IRRIT.
======================= First Aid Measures =======================
First Aid:INHAL:RMV TO FRESH AIR. IF NOT BRTHNG GIVE CPR; IF BRTHNG
DIFF GIVE OXYGEN. EYE:IMMED FLUSH W/PLENTY OF WATER. SKIN:WASH
W/SOAP&WATER. RMV CONTAM CLTHG&SHOES. INGEST:INDUCE VOMIT. RPT
UNTIL VOMIT IS C LEAR. NOTHG BY MOUTH IF UNCONSC. GET MEDICAL ATTN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:680C
Extinguishing Media:MATL IS NON-FLAMMABLE. USE AGENT SUITABLE FOR
SURROUND FIRE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA. USE WATER SPRAY TO
COOL CONTAINERS
Unusual Fire/Explosion Hazard:AVOID CONTACT W/ACTIVE METALS. HEAT
DECOMPOSITION PRODUCTS ARE HALOGENS, HALOGEN ACIDS, & PHOSGENE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE UNPROTECTED PERSONNEL. ELIMIN ANY
FLAMES. SHUT OFF LEAK. ABSORB LIQ SPILL W/INERT MATL. SHOVEL INTO
METAL DRUMS,CLOSE & DISPOSE. DIKE LG AMTS W ABSORBENT & PUMP INTO
DRUMS FOR RECLAMATION OR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A CLEAN, COOL, DRY AND WELL
VENTILATED AREA OF LOW FIRE RISK. PROTECT CONTAINERS FM PHYSICAL
DAMAGE AND KEEP CLOSED WHEN NOT IN USE.
Other Precautions:TANKS CANNOT BE EFFECTIVELY FLUSHED OF VAPOR IF SUMP
CONTAINS LIQUID, "EMPTY" CONTAINER MAY CONTAIN PRODUCT RESIDUES
(VAPOR OR LIQUID). RMV CLOSURES CAREFULLY TO RELIEVE POSSIBLE
PRESSURE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED SCBA FOR ENCLOSED AREAS.
Ventilation:LOCAL IF SPILL LIKELY MECHANICAL (GEN) REQD.
Other Protective Equipment:EYE WASH STATIONS. SAFETY SHOWERS,
IMPERVIOUS APRON IF REQD.
Supplemental Safety and Health
MSDS DATED OCT 1985. ***POWDERED TITANIUM,CALCIUM,MAGNESIUM,ZINC &
BERYLLIUM ARE INCOMPATIBLE & MAY REACT VIOLENTLY.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:117F,47.6C
Vapor Pres:284
Vapor Density:6.45
Spec Gravity:1.57
Evaporation Rate & Reference:2 (ETHER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID, FAINT ETHEREAL ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALUMINUM POWDER,FINELY DIVIDED BARIUM,LITHIUM SHAVINGS ***
Stability Condition to Avoid:TEMPERATURES ABOVE 482F,250C CAUSE
THERMAL/OXIDATIVE DECOMP.
Hazardous Decomposition Products:HALOGENS,HF,HCL, & CARBONYL HALIDES
SUCH AS PHOSGENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W ALL LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:STARTING FLUID J.I. CASE 10.4 OZ
Preparer's Name:DEREK J. BEMIS
CAGE:2M612
CAGE:2M612
============= Composition/Information on Ingredients =============
Ingred Name:N-HEPTANE; (HEPTANE, RELATED LIGHT HYDROCARBONS)
CAS:142-82-5
RTECS #:MI7700000
OSHA PEL:500 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9293
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED (SEVERE)
LIGHT NAPHTHENIC. PEL/TLV AS OIL MIST.
CAS:64742-53-6
RTECS #:PY8036001
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3; 10 STEL
Ingred Name:METHANE, 2,2'-BIS(6-T-BUTYL-P-CRESYL)-; (2,2'-METHYLENEBIS
(4-METHYL-6-TERTIARYBUTYL PHENOL))
CAS:119-47-1
RTECS #:PA3500000
Ingred Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM/30000STEL;93
Ingred Name:ETHANE, 1,1'-OXYBIS-; (ETHYL ETHER) (DIETHYL ETHER). BP:
94F. FL PT: -56F. LEL: 1.8%. UEL: 48%.
CAS:60-29-7
RTECS #:KI5775000
OSHA PEL:400 PPM;500 PPM STEL
ACGIH TLV:400 PPM;500 PPM STEL
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: DIZZINESS, STRONG ANESTHESIA,
INTOXICATION, UNCONSCIOUSNESS. SKIN: IRRITATION UPON PROLONGED
CONTACT, DEFATTING OF SKIN. EYE: IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. ARTIFICIAL RESPIRATION, GET
IMMEDIATE MEDICAL ATTENTION. SKIN: FLUSH AREA WELL WITH WATER.
REMOVE AND WASH ANY CLOTHING SOAKED WITH PRODUCT. EYE: FLUSH EYES
WELL WITH RUNNI NG WATER FOR AT LEAST 15 MINUTES. INGEST: CALL MD
OR POISON CONTROL CENTER IMMEDIATELY. PROPER TREATMENT IS DEPENDENT
ON CONDITION OF PATIENT AND AMOUNT INGESTED.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:SEE INGREDIENT 2
Lower Limits:SEE ING 2
Upper Limits:SEE ING 2
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, WATER-FOG OR MIST
ONLY, ALCOHOL FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . AVOID POSSIBLE ACCUMULATIONS OF FLAMMABLE
VAPORS AT LOW LEVELS, AS VAPOR IS HVR THAN AIR.
Unusual Fire/Explosion Hazard:AVOID POSS BURSTING OF AEROSOL CAN. DO
NOT STORE WHERE TEMP MAY EXCEED 120F. DO NOT PUNCTURE/ INCINERATE.
PROD IS EXTREMELY FLAMM AT ALL TIMES. (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP AWAY FROM HEAT, FIRE, SPARKS OR FLAME.
VENTILATE AREA WELL. CO*2 MAY BE USED AS A PRECAUTIONARY VAPOR
BLANKET. SMALL AMOUNTS MAY BE FLUSHED AWAY WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE WHERE TEMPERATURE MAY
EXCEED 120F. DO NOT STORE NEAR HEAT, FIRE, FLAME, OR SPARKS.
Other Precautions:AVOID EXCESSIVE BREATHING OF VAPOR. DO NOT SPRAY IN
DIRECTION OF BODY. USE ONLY I/A/W DIRECTIONS. AVOID CONTACT WITH
SKIN, EYES, OR CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV IS EXCEEDED WEAR NIOSH/MSHA APPROVED
SELF-CONTAINED BREATHING DEVICE OR RESPIRATOR.
Ventilation:MUST BE ADEQUATE TO MAINTAIN VAPORS AT LESS THAN 400 PPM,
PARTICULARLY AT FLOOR LEVEL AS VAPORS ARE HEAVIER THAN AIR.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
APPEAR/ODOR:SLIGHT LUBRICANT RESIDUE. VP:80 PSIG IN CAN. EXPLO
HAZ:AVOID INADVERTENT IGNIT SOURCES, INCLUDING STATIC SPK. UNSTABLE
EXPLOSIVE PEROXIDES MAY BE FORMED & CONCENTRATED BY EVAP TO HAZ
LEVEL S. THIS PROCESS IS FAVORED BY PRLNGD STORAGE W/EXPOS TO AIR &
LIGHT. GENERALLY STABLE IN SEALED METAL CONTAINERS.
================== Physical/Chemical Properties ==================
HCC:G2
Boiling Pt:B.P. Text:SEE ING 2
Vapor Pres:SUPP DATA
Vapor Density:APPROX 2.5
Spec Gravity:0.7 (H*20=1)
Evaporation Rate & Reference:APPROX 6 (BUAC=1)
Solubility in Water:APPROX 6% @ 70F.
Appearance and Odor:PALE YELLOW TO CLEAR LIQ;STRONG ETHEREAL ODOR,
EVAPS QUICKLY, LEAVES (SUPP DATA
Percent Volatiles by Volume:99(WT)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
STRONG OXIDIZERS.
Stability Condition to Avoid:HEAT, SPARKS, FLAMES, EVAPORATION,
PROLONGED EXPOSURE TO AIR AND LIGHT.
Hazardous Decomposition Products:CARBON MONOXIDE MAY FORM ON
COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF PROMPTLY IN SEALED METAL CONTAINERS
I/A/W ALL LOCAL, STATE AND FEDERAL REGULATIONS. AVOID ANY
CONTAMINATION OF GROUNDWATER.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MIL-C-22750F, ACTIVATOR, PART B FOR SEMI & FLAT, UO-137
Kit Part:Y
Preparer's Name:DAVID SCHMETTERER
CAGE:DO165
CAGE:DO165
CAGE:5V430
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III) (VP =
71.2 MMHG)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 48.0%
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:NH2CH2CH(CH3)(CH2)3NH2 (VP=130.0 MMHG)
CAS:15520-10-2
RTECS #:SA0248500
Fraction by Wt: 14.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT EST.
ACGIH TLV:NOT EST.
Ingred Name:PHENYL CARBINOL (MAY CONTAIN AS IMPURITIES: 100-52-7
BENZALDEHYDE 0.3%, 103-50-4 DIBENZYL ETHER 0.1%, 150-76-5 0.025%
CAS:100-51-6
RTECS #:DN3150000
Fraction by Wt: 13.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:EPOXY RESIN
CAS:25085-99-8
Fraction by Wt: 5.7%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:REPEATED/PROLONGED OCCUPATIONAL
OVEREXPOSURE TO SOLVENTS ASSOCIATED W/PERMANENT BRAIN/NERVOUS
SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND
INHALING THE CONTENTS MAY BE HARMFUL O R FATAL. PROLONGED
OVEREXPOSURE (INHAL)MAY CAUSE DELAYED LUNG DISEASE.
Explanation of Carcinogenicity:MAY CONTAIN TRACE AMTS OF SOME CHEM
KNOWN TO THE STATE OF CATO BE CARCINOGENS OR REPRODCTIVE TOXINS.
Effects of Overexposure:OVEREXPOSURE MAY PRODUCE VARIOUS EFFECTS. ACUTE
TOXICITY (HEADACHE, DIZZINESS, NAUSEA, LOSS CONSCIOUSNESS. SEVERE
EYE IRRITATION POSSIBLY RESULTING PERMANENT DAMAGE. IRRITATED
MUCOUS MEMBRANES. VOMITI NG FROM INGESTION. SKIN DEFATTING/DRYING.
SENSITIZATION AFTER REPEATED CONTACT.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/PLENTY CLEAN H20 15 MIN, LIFTING LIDS, GET MED
ATTN. INHAL: GET FRESH AIR, PROVIDE OXYGEN IF BREATH DIFFICULT.
GIVE ARTIF RESP IF NOT BREATHING. GET MED ATTN. KEEP VICTIM
WARM/QUIET. NEVE R GIVE UNCONS PERSON LIQ. INGEST: CALL DR. IMMED.
DON'T INDUCE VOMIT. IF VOMIT SPONTANEOUSLY, KEEP HEAD BELOW HIPS.
SKIN: FLUSH W/H20 WHILE REMOVING CONTAM CLOTHES/SHOES. IF IRRIT
PERSIST, GET MED AID
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:22.0F,-5.6C
Lower Limits:1.8
Extinguishing Media:FOAM, CO2, OR DRY CHEMICAL
Fire Fighting Procedures:WATER MAY BE USED TO KEEP EXPOSED CONTAINERS
COOL & KEEP FLAMMABLE STRUCTURE WETDON'T ENTER FIRE AREA WITHOUT
PROPER PROTECTION, HAZARDOUS DECOMP MAY BE PRESENT
Unusual Fire/Explosion Hazard:WATER PRESSURE MAY SPREAD A FLAMMABLE
LIQUID FIRE. SEALED CONTAINERS MAY EXPLODE IF OVER HEATED.
================== Accidental Release Measures ==================
Spill Release Procedures:WARNING - FLAMMABLE. ELIMINATE ALL IGNITION
SOURCES. HANDLING EQUIPMENT MUST BE GROUNDED TO PREVENT SPARKING.
SOAK UP WITHABSORBENT & PLACE IN NON-LEAKING CONATINERS. SEAL
TIGHTLY FOR PROPER DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:TREAT AS A HAZARDOUS-FLAMMABLE
MATERIAL. KNOW APPLICABLE D.O.T. REG. BEFORE ATTEMPTING TO
TRANSPORT THIS MATERIAL.
Other Precautions:WARNING: HOT ORGANIC CHEMICAL VAPORS OR MISTS ARE
SUSCEPTIBLE TO SUDDEN SPONTANEOUS COMBUSTION WHEN MIXED W/AIR.
IGNITION MAY OCCUR @ TEMPS BELOW THOSE PUBLISHED AS
AUTOIGNITION/IGNITION TEMPS. IGNITI ON TEMPS DECREASE W/INCREASING
VAPOR*
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IMPORTANT-MUST PROVIDE ADEQUATE VENT TO MAINTAIN
VAPOR CONCENTRATE BELOW ESTAB- LISHED TLV LIMIT AS GIVEN BY OSHA.
IN MORE CONFINED AREAS A NIOSH/MSHA APPROVED RESPIRATOR EQUIPPED
WITH ORGANIC VAPOR C ARTRIDGE SHOULD BE WORN.
Ventilation:MUST PROVIDE ADEQUATE VENTILATION, SEE PARAGRAPH ABOVE.
Other Protective Equipment:HAVE EYE BATH & SAFETY SHOWER AVAILABLE.
Supplemental Safety and Health
VOLUME AND VAPOR/AIR CONTACT TIME AND ARE INFLUENCED BY PRESSURE
CHANGES. IGNITION MAY OCCUR AT TYPICAL ELEVATED TEMPERATURE PROCESS
CONDITIONS, ESPECIALLY IN PROCESS OPERATING UNDER VACUUM IF SUBJECT
ED TO SUDDEN INGRESS OF AIR, OUTSIDE PROCESS EQUIPMENT OPERATING
UNDER ELEVATED PRESSURE IF SUDDEN ESCAPE OF VAPORS/MIST
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:175 TO 401F
Vapor Density:>AIR
Spec Gravity:1.06
Viscosity:70 KU
Evaporation Rate & Reference:3.77 X N-BUTYL ACETATE
Solubility in Water:SLIGHT
Appearance and Odor:CLEAR LIQUID
Percent Volatiles by Volume:80.9
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS & STRONG ALKALIES. NOT CORROSIVE TO METAL.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAMES, STRONG
ALKALIES, & OXIDIZING AGENTS.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION OR PRODUCTS LIKE
THIS MAY GENERATE HIGHLY POISONOUS CARBON MONOXIDE AND OTHER TOXIC
GASES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH CURRENT
LOCAL, STATE & FEDERAL REG. CONTACT AN APPROVED DISPOSAL FACILITY
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:2541 FEEDWATER TREATMENT
Preparer's Name:JOHN J. KASPER
CAGE:89524
CAGE:89524
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 1-10%
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HYDRAZINE (SARA III). LD50: (ORAL,RAT) 60 MG/KG.
CAS:302-01-2
RTECS #:MU7175000
Fraction by Wt: 1-10%
OSHA PEL:S, 1 PPM
ACGIH TLV:S, 0.1 PPM, A2; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ACETIC ACID, NITRILOTRI-, TRISODIUM SALT, MONOHYDRATE;
(SODIUM NITRILOTRIACETIC ACID). LD50: (ORAL,RAT) 2,595 MG/KG.
CAS:18662-53-8
RTECS #:AJ1070000
Fraction by Wt: 1-10%
Ingred Name:SUPP DATA:SPECIFIED IN PERSONAL PROT EQUIP.PROD IS TOX TO
FISH. IT SHOULD NOT BE DIRECTLY DISCHARGED INTO LAKES, (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: PONDS, STREAMS, WATERWAYS OR PUBLIC WATER SUPPLIES.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH: INJECTED IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS.
RTECS #:9999999ZZ
Ingred Name:HYGIENE PRACT: SHOES AND LEATHER ITEMS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYE:CAN CAUSE MOD IRRIT. SKIN:CAN
CAUSE SEV IRRIT. INGEST:CAN BE HARMFUL. INHAL:MAY CAUSE IRRIT TO
RESP TRACT & LUNGS. HYDRAZINE MAY CAUSE DERM, SENSIT,DMG TO LIVER,
KIDNEYS, LUNGS, BLOOD FORMING ORGA NS, & NEUROLOGICAL CHANGES.
BASED ON LIFETIME FEEDING STUDIES OF 1.5% SODIUM SALT OF
NITRILOTRIACETIC (EFTS OF OVEREXP)
Effects of Overexposure:HLTH HAZ: ACID W/MICE & RATS, SIGNIFICANT INCR
IN URINARY TRACT TUMORS WERE NOTED. ORAL ADMIN OF HYDRAZINE PRDCED
LUNG & LIVER TUMORS IN MICE & RATS & MAMMARY TUMORS IN MICE.
INTRAPERITONEAL ADMIN IN MICE PRDCED LUNG TUMORS & SARCOMAS. RPTD
INHAL EXPOS TO 1PPM IN RATS RSLTD IN NASAL TUMORS, WHICH WAS DOSE
RELATED.
Medical Cond Aggravated by Exposure:A REVIEW OF AVAILABLE DATA DOES NOT
IDENTIFY ANY WORSENING OF EXISTING CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYES:IMMED FLUSH W/H2O FOR AT LEAST 15 MIN WHILE HOLDING
EYELIDS OPEN. CALL PHYS AT ONCE. SKIN:IMMED FLUSH W/H2O FOR AT
LEAST 15 MIN. FOR LRG SPLASH, FLOOD BODY UNDER SHOWER. CALL PHYS AT
ONCE. INGEST : DO NOT INDUCE VOMIT. GIVE H2O. CALL PHYS. NOTE TO
PHYS: NO SPECIFIC ANTIDOTE IS KNOWN. BASED ON INDIV RXNS OF
PATIENT, PHYS JUDGMENT SHOULD BE USED TO CNTRL SYMP & CLINICAL
CNDTN. CAUTN: (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:NONE
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE CONDITIONS
.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MAY EVOLVE NOX UNDER FIRE CONDITIONS.
CONTAINERS EXPOSED IN FIRE SHOULD BE COOLED WITH WATER TO PREVENT
VAPOR PRESSURE BUILDUP LEADING TO RUPTURE.
================== Accidental Release Measures ==================
Spill Release Procedures:SML LIQ SPILLS: CONTAIN W/ABSORB MATL, SUCH AS
SAW DUST, CLAY, SOIL/ANY COMMERCIALLY AVAIL ABSORB. SHOVEL
RECLAIMED LIQ & ABSORB INTO RECOVERY/SALVAGE DRUMS FOR DISP. REFER
TO CERCLA. LRG LIQ SPILLS:D IKE TO PVNT FURTHER MOVEMENT & RECLAIM
(ING 4)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTAINS HYDRAZINE & NITRILOTRIACETIC
ACID SALTS:POSS CANCER HAS BASED ON TESTS W/LAB ANIMALS.
WARNING:CAUSES EYE INJ & SKIN IRRIT.DO NOT GET IN EYES.
Other Precautions:AVOID CONTACT WITH SKIN & CLTHG. WEAR GOG/FACESHIELD
WHEN HNDLG. AVOID PRLNGD/RPTD BREATHING OF VAPORS. DO NOT TAKE
INTERNALLY. EMPTY CONTAINERS MAY CONTAIN RESIDUAL PRODUCT. DO NOT
REUSE CONTAINER UN LESS PROPERLY RECONDITIONED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF POSS TO GENERATE SIGNIFICANT LEVS OF VAPS/
MISTS, A NIOSH/MSHA APPRVD/EQUIV RESP IS RECOM. FOR LRG SPILLS,
ENTRY INTO LRG TANKS, VESSELS/ENCLOSED SML SPACES W/INADEQ VENT, A
NIOSH/MSHA APPRVD PRESS -DEMAND, SCBA IS RECOMMENDED.
Ventilation:GENERAL VENT IF RECOM. ADDITIONALLY, LOCAL EXHAUST
VENTILATION IS RECOMMENDED WHERE VAPORS, MISTS/AEROSOLS MAY BE
RELSD.
Other Protective Equipment:WEAR BOOTS AND AN APRON. A FULL SLICKER SUIT
IS RECOM IF GROSS EXPOSURE IS POSS. EYE WASH FOUNTAIN & SAFETY
SHOWER.
Work Hygienic Practices:IF CLTHG IS CONTAM, REMOVE CLTHG & THORO WASH
AFFECTED AREA. LAUNDER CONTAM CLTHG BEFORE REUSE. DISCARD CONTAM
(ING 7)
Supplemental Safety and Health
PH: (NEAT)13.1; (@ 1%)11.4. FIRST AID PROC: IF UNCON, HAVING TROUBLE
BRTHG/IN CONVULSNS, DO NOT INDUCE VOMIT/GIVE H2O. SPILL PROC: INTO
RECOVERY/SALVAGE DRUMS/TANK TRUCK FOR DISP. REFER TO CERCLA. FOR
LRG INDOOR SPILLS, EVAC EMPLOYEES & VENT AREA. THOSE RESPONSIBLE
FOR CNTRL & RECOVERY SHOULD WEAR PROT EQUIP (ING 4)
================== Physical/Chemical Properties ==================
HCC:C2
Boiling Pt:B.P. Text:210F,99C
Vapor Density:8.9
Spec Gravity:1.07 @ 77F
pH:SUPDAT
Solubility in Water:COMPLETELY
Appearance and Odor:LIGHT BROWN/YELLOW LIQUID, AMMONIA ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALUMINUM, BRASS, NICKEL, STRONG ACIDS (EG. SULFURIC, PHOSPHORIC,
NITRIC, HYDROCHLORIC, CHROMIC, SULFONIC).
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:IN EVENT OF COMBUSTION CO, CO2, NOX
MAY BE FORMED.
==================== Disposal Considerations ====================
Waste Disposal Methods:IF PROD BECOMES WASTE,IT MEETS CRITERIA OF HAZ
WASTE AS DEFINED UNDER RCRA 40 CFR 261. HAZ WASTE D002. AS HAZ LIQ
WASTE, IT MUST BE SOLIDIFIED BEFORE DISP IN LANDFILL (HAZ WASTE
TREATMENT, STOR & DISP FACILITY). CAN BE INCIN. CAN BE DEEP-WELL
(ING 6)
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:THORIA TUNGSTEN ELECTRODES;TIG AND GTA WELDING ELECTRODES
CAGE:KO078
CAGE:98251
CAGE:1HJ95
CAGE:KO078
============= Composition/Information on Ingredients =============
Ingred Name:TUNGSTEN
CAS:7440-33-7
RTECS #:YO7175000
Fraction by Wt: 98-99%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3/ 10 STEL
ACGIH TLV:5 MG/M3/10 STEL;9192
Ingred Name:THORIUM DIOXIDE (SARA III)
CAS:1314-20-1
RTECS #:XO6950000
Fraction by Wt: 1-2%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES
Health Hazards Acute and Chronic:NORMAL HANDLING OF THESE ELECTRODES
ARE NOT EXPECTED TO RESULT IN ANY SIGNIFICANT EXTERNAL RADIATION
EXPOSURE. THORIUM DIOXIDE IS AN ALPHA EMITTER AND, AS SUCH, ITS
PRIMARY HAZARD LIES IN INHALATION O F DUST/FUMES. SHORT TERM
OVEREXPOSURE TO WELDING FUMES MAY RESULT IN DIZZINESS, NAUSEA,
IRRITATION OF EYES, NOSE,THROAT.
Explanation of Carcinogenicity:THORIUM DIOXIDE IDENTIFIED AS CARCINOGEN
BY NTP AND IARC. CANCER EVIDENCE HAS COME SOLELY FROM ITS INTERNAL
MEDICAL USE.
Effects of Overexposure:SHORT-TERM OVEREXPOSURE: DIZZNESS, NAUSEA,
IRRITATION OF EYES, NOSE, AND THROAT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FOR IRRITATION DUE TO WELDING FUMES, FLUSH WITH LARGE
AMOUNTS OF WATER. IF IRRITATION PERSISTS, GET MEDICAL ATTENTION.
SKIN: ADVERSE REACTIONS FROM CONTACT WITH ELECTRODES ARE UNLIKELY.
FOR WELD ING IRRITATION/BURNS, GET MEDICAL ATTENTION. INHALATION:
IF IRRITATION, DISCOMFORT OR OTHER SIGNS OF PULMONARY INVOLVEMENT
DEVELOPS DURING WELDING, MOVE TO FRESH AIR AND GET MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NON FLAMMABLE. USE MEDIA APPROPRIATE FOR
SURROUNDING FIRE.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:WELDING ARC AND SPARKS CAN IGNITE
COMBUSTIBLES.
================== Accidental Release Measures ==================
Spill Release Procedures:NOT APPLICABLE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH APPROVED FUME RESPIRATOR WHEN
WELDING IN CONFINED SPACES AND WHENEVER FUME CONCENTRATIONS EXCEED
APPLICABLE LIMITS FOR THORIUM, TUNGSTEN, OR OTHER WELDING FUMES.
ALL APPROPRIATE REQUIREMEN TS IN 29 CFR 1910.134 SHOULD BE MET.
Ventilation:USE ADEQUATE GENERAL VENTILATION/LOCAL EXHAUST AT THE ARC
TO KEEP FUMES/GASES BELOW APPLICABLE LIMITS IN WORKING AREA.
Other Protective Equipment:PROVIDE PROTECTIVE SCREENS AND FLASH
Work Hygienic Practices:NORMAL PRACTICE IS ADEQUATE.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:T7
Boiling Pt:B.P. Text:10220F,5660
Spec Gravity:19
Solubility in Water:INSOLUBLE
Appearance and Odor:GRAY METAL/NO ODOR.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:WELDING FUMES (OXIDES OF METAL BEING
WELDED AND GASES DEPENDING ON THE PROCESS, PROCEDURE AND METAL
WELDED.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPROPRIATE
GOVERNMENT REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CONDUCTIVITY STD MHOS, 281
CAGE:24774
CAGE:24774
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: SKIN: NON-HAZARDOUS TO SKIN.
EYES: SLIGHTLY IRRITATING TO EYES. INHALATION: PRIMARY ROUTE OF
EXPOSURE. MISTS/AEROSOLS MAY CAUSE IRRITATION TO UPPER RESPIRATORY
TRACT. CHRONIC: NO EVIDENCE OF PO TENTIAL CHRONIC EFFECTS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:MAY CAUSE EYE, SKIN AND/OR RESPIRATORY TRACT
IRRITATION.
Medical Cond Aggravated by Exposure:NOT KNOWN.
======================= First Aid Measures =======================
First Aid:SKIN: REMOVE CONTAMD CLTHG. WASH EXPOSED AREA W/LARGE QTY OF
SOAP SOLUTION OR WATER FOR 15 MIN. EYES: IMMED FLUSH EYES W/WATER
FOR AT LEAST 15 MIN. IMMED CONTACT MD FOR ADDNL TREATMENT. INHAL:
REMOVE FROM CONTAMD AREA TO FRESH AIR. APPLY APPROP FIRST AID
TREATMENT AS NECESSARY. INGEST: GENERAL- DO NOT FEED ANYTHING BY
MOUTH TO AN UNCON/CONVULSIVE VICTIM. SPECIFIC: NO TREATMENT REQD
-NO HAZARD.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, FOAM OR WATER.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:GEN: VENT AREA. USE SPECIFIED PROT EQUIP.
CONTAIN & ABSORB ON ABSORBENT MATL. PLACE IN WASTE DISPOSAL CNTNR.
WASTE CHARACTS OF ABSORBED MATL OR ANY CONTAMD SOIL SHOULD BE
DETERMINED I/A/W RCRA REGS. S PECIFIC - FLUSH AREA W/WATER. WET
AREA (SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
DO NOT FREEZE. IF FROZEN, THAW AND MIX COMPLETELY PRIOR TO USE.
Other Precautions:THIS REAGENT IS NON-HAZARDOUS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATORS WITHIN USE
LIMITATIONS OR ELSE USE NIOSH APPROVED SUPPLIED AIR RESPIRATORS. IF
VENTILATION IS INADEQUATE OR SIGNIFICANT REAGENT EXPOSURE IS
LIKELY, USE NIOSH APPROVED RE SPIRATOR WITH DUST/MIST FILTERS.
Ventilation:ADEQUATE VENTILATION.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER . USE
PROTECTIVE EQUIPMENT I/A/W 29 CFR SECTION 1910.132-134.
NECESSARY.
Supplemental Safety and Health
SPILL PROC: MAY BE SLIPPERY. SPREAD SAND/GRIT.
================== Physical/Chemical Properties ==================
Spec Gravity:0.990
Evaporation Rate & Reference:<1 ETHER=1
Solubility in Water:100%
Appearance and Odor:COLORLESS LIQUID; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:THERMAL DECOMPOSITION (DESTRUCTIVE
FIRES) YIELDS ELEMENTAL OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FED, STATE & LOCAL REGS .
GEN: WATER CONTAMD W/THIS REAGENT MAY BE SENT TO SANITARY SEWER,
I/A/W ANY LOCAL AGREEMENT, A TREATMENT FACILITY OR DISCHARGED UNDER
NPDES PERMIT . REGENT (AS IS):INCIN OR BURN IN APPRVD LANDFILL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SPARVAR INTERIOR/EXTERIOR SPRAY PAINT DOVE
CAGE:FO774
CAGE:86142
CAGE:FO774
============= Composition/Information on Ingredients =============
Ingred Name:HEXANE
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: 14-22%
OSHA PEL:500 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:1-METHOXY 2-PROPANOL ACETATE; (2-PROPANOL, 1-METHOXY-,
ACETATE)
CAS:108-65-6
RTECS #:AI8925000
Fraction by Wt: 8.0%
ACGIH TLV:NOT ESTAB (MFR)
Ingred Name:VM&P NAPHTHA
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 15-25%
OSHA PEL:300 PPM/400 STEL
ACGIH TLV:300 PPM; 9192
Ingred Name:SUPDAT:PROGRAMS ARE ADEQUATE.
RTECS #:9999999ZZ
Ingred Name:ACETONE (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 18-23%
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 18-20%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9192
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INGEST:NOT EXPECTED TO BE
HARMFUL UNDER NORMAL CNDTNS OF USE. INHAL:MAY BE HARMFUL IF
INHALED. LIQ/VAP CAN CAUSE IRRIT OF NOSE, THROAT & LUNGS.
SKIN/EYE:CAUSES IRRIT. INGS 1 & 5:CAN CAUSE CNS DE PRESS. SIGNS &
SYMPS MAY INCL HDCH, DIZZ, NAUS, VOMIT, UNCON & EVEN ASPHY. ING
2:MATL IS SIMPLE ASPHY. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:SIGNS & SYMPS OF OVEREXP INCL
CYANOSIS, RESP DISTRESS, HDCH, DIZZ, DROW, UNCON & ASPHY. CAN CAUSE
CNS DEPRESS. ING 3:CHRONIC EXPOS HAVE CAUSED PERIPHERAL NEUROPATHY.
CAN CAUSE CNS DEPRESS, SI GNS & SYMPS MAY INCL HDCH, DIZZ, NAUS,
VOMIT & DROW.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN:IMMED FLUSH W/WATER FOR @ LST 15 MINS. IF IRRIT
PERSISTS, CALL MD. INGEST:DILUTE BY DRINKING LG QTYS OF WATER.
IMMED CONT POIS CTL CTR/HOSP EMER RM FOR ANY OTHER ADDNL TREATMENT
DIRECTIONS. INHAL :REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTF
RESP, PREF MOUTH-TO-MOUTH. IF BRTHG IS DFCLT, GIVE OXYGEN, CALL MD.
EYES:IMMED FLUSH W/PLENTY OF WATER FOR @ LST 15 MINS. EYELIDS
SHOULD BE HELD (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:EXTREMELY FLAMM
Extinguishing Media:DRY CHEMICAL,FOAM/CO*2;H*20 MAY BE INEFFECTIVE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . USE WATER TO COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CONTENTS UNDER PRESS; EXPOS TO HIGH TEMPS
MAY CAUSE POSS BURSTING. AVOID HEAT SOURCES. DON'T PUNCTURE/BURN
CNTNR. DON'T SPRAY NEAR OPEN FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES.SOAK UP WITH
ABSORBENT MATERIAL & REMOVE TO AA CHEMICAL DISPOSAL AREA. PREVENT
ENTRY INTO NATURALBODIES OF H*20.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE AT TEMP OVER 120F. AVOID
EYE, SKIN/CLTHG CONT. AVOID BRTHG VAP/MIST. USE W/ADEQ VENT.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE AIR CONTAMINANTS EXCEED ACCEPTABLE
CRITERIA, USE NIOSH/MSHA APPROVED RESPIRATORY PROTECTION EQUIPMENT.
REFER TO OSHA 29 CFR 1910.134 AS GUIDELINE.
Ventilation:SUFFICIENT VENT IN VOL & PATTERN TO KEEP CONTAMINANT LEVELS
BELOW ACCEPT CRITERIA:LOC EXHST VENT, ENCLSD SYS (SUPDAT)
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. HANDLE W/GOOD
INDUSTRIAL HYGIENE & SAFETY PRACTICES.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:GRAY, S-113. VP:60 PSIG @ 70F. % VOLAT BY
VOL:78-89 (WT). FIRST AID PROC:APART DURING IRRIGATION TO INSURE
WATER CONT W/ENTIRE SURF OF EYES & LIDS. CALL MD. VENT:DESIGN,
PROCE SS ISOLATION, REMOTE CONTROL IN COMBINATION W/PROT EQUIP &
PRUDENT WORK PRACTS. CONSULT W/EXPERTS TO DETERM IF (ING 6)
================== Physical/Chemical Properties ==================
HCC:V3
Vapor Pres:SUPP DATA
Vapor Density:HVR/AIR
Spec Gravity:LIGHTER/WATER
Evaporation Rate & Reference:FASTER THAN BUAC
Solubility in Water:SLIGHT
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL,STATE &
FEDERAL REGULATIONS. EMPTY CONTAINERS MAY CONTAIN EXPLOSIVE VAPORS.
DONT CUT,PUNCTURE OR WELD ON OR NEARBY. INCINERATION WILL CAUSE
CONTAINER TO BURST VIOLE NTLY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:7533/3
CAGE:53021
CAGE:53021
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMED.SKIN:WASH W/SOAP IMMED.INHAL:REMOVE
TO FRESH AIR.GIVE ART.RESPIR. AS NEEDED.INGEST:GET MEDICAL
ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE VOMITING,BUT DO NOT MAKE
UNCONSCIOUS PE RSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS.CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE,THROAT
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW COLORED LIQUID,AROMTIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | eyes_protection_mandatory |
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.