text
stringlengths 542
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:MEAN GREEN
CAGE:EO652
CAGE:26264
CAGE:EO652
============= Composition/Information on Ingredients =============
Ingred Name:HEXYLENE GLYCOL
CAS:107-41-5
RTECS #:SA0810000
Fraction by Wt: 3%
OSHA PEL:C 25 PPM
ACGIH TLV:C 25 PPM; 9192
======================= First Aid Measures =======================
First Aid:EYES: FLUSH THOROUGHLY W/WATER & SEEK MEDICAL ATTENTION.
INGESTION: GIVE 1 OR 2 GLASSES OF MILK OR WATER. CALL PHYSICIAN.
SKIN: WASH OFF WITH WATER. IF IRRITATION OCCURS & PERSISTS. OBTAIN
MEDICAL ATT ENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER FREE LIQUID. SPILLS CAN USUALLY BE
FLUSHED WITH WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING MISTS. AVOID CONTACT
WITH EYES. KEEP CONTAINER CLOSED. WASH AFTER HANDLING. STE BETWEEN
30-120F.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE. NIOSH/MSHA RESPIRATOR IF MISTING OCCURS.
_
Ventilation:MECHANICAL/LOCAL EXHAUST: NO SPECIAL REQUIREMENT.
Other Protective Equipment:NONE
Supplemental Safety and Health
02/86. AROMATIC POLYOXYALKALINE (A NON-IONS SURFACTANT) USAFOEHL
ANALYSIS. THIS PRODUCT IS A LIQUID, SYNTHETIC DETERGENT. ESN'T
CONTAINS STRONG CAUSTICS, NTA, OR ENZYMES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F
Vapor Pres:23.
Vapor Density:<1
Spec Gravity:1.1
Evaporation Rate & Reference:(WATER = 1) <1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR GREEN LIQUID WITH A MILD LEMON FRAGRANCE.
Percent Volatiles by Volume:77%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIALS.
==================== Disposal Considerations ====================
Waste Disposal Methods:NORMAL FOR CLEANING COMPOUNDS IN YOUR AREA.
CONSULT FEDERAL, STATE OR LOCAL DISPOSAL AUTHORITIES FOR APPROVED
PROCEDURES. INCINERATE IN A FURNACE WHERE PERMITTED UNDER
APPROPRIATE FEDERAL, STATE AND L OCAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:4311 (MAGMA CRI) SOLIDIFIER, 3306/1284
Preparer's Name:J PARTINGTON
CAGE:0PX05
CAGE:0PX05
============= Composition/Information on Ingredients =============
Ingred Name:DIETHYLENETRIAMINE LD50 (ORAL RAT): 1080 MG/KG
CAS:111-40-0
RTECS #:IE1225000
Fraction by Wt: 10-30%
OSHA PEL:1 PPM
ACGIH TLV:1 PPM, S
Ingred Name:OTHER PROT EQUIP: OF CONTAMINATION OF FOOTWEAR, SAFETY
BOOTS SHOULD BE WORN & CLEANED THOROUGHLY BEFORE REUSE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CAUSES BURNS TO SKIN AND EYES.
CHRONIC: CHEMICAL BURNS AND SENSITIZATION.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:SKIN AND EYE CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHAL: IF SYMPS ARE EXPERIENCED, REMOVE SOURCE OF CONTAM
&/MOVE VICTIM TO FRESH AIR. IF RECOVERY IS DELAYED/THERE ARE SIGNS
OF DISTRESS OBTAIN MED ATTN. EYES: FLUSH W/WATER FOR AT LEAST 15
MIN. IMMEDFIRST AID IS NEC TO PVNT EYE DMG. SEEK MED ADVICE IF
ANY IRRIT PERSISTS. SKIN: IMMED REMOVE EXCESS W/CLEAN CLOTH & WASH
THORO W/SOAP & WATER. IF IRRIT/INFLAMM PERSISTS, SEEK MED ADVICE.
(SUP DAT)
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>212F,>100C
Extinguishing Media:WATER FOG (NOT A DIRECT STREM OF WATER), FOAM,
CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . USE SAND TO CONTAIN BURNING MATERIAL.
Unusual Fire/Explosion Hazard:DECOMPOSITION AND COMBUSTION PRODUCTS MAY
BE HAZARDOUS.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH AN INERT MATERIAL (E.G., EARTH OR
SAND). SWEEP UP, PLACE INTO SUITABLE LABELLED CONTAINERS, SEAL AND
DISPOSE OF PROPERLY. FLUSH AREA WITH DETERGENT AND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING VAPORS & CONTACT
W/SKIN & EYES. OVERHEATING MAY CAUSE CONTAINERS TO RUPTURE.
CONTAINERS SHOULD BE STORED UNDER COOL, DRY CONDITIONS.
Other Precautions:EMPTY CONTAINERS WILL RETAIN RESIDUE AND MAY BE
DANGEROUS. CHECK ALL CONTAINERS FOR LEAKS AT REGULAR INTERVALS AND
BEFORE REUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN CONFINED AREAS/WHERE GOOD NATRL/MECH VENT IS
NOT AVAIL, LEADING TO RISK OF EXCEEDING TLV'S INDICATED, AN APPROP
NIOSH APPRVD RESP SHOULD BE WORN. WHERE MACHINING/ABRADING OF CURED
MATL LEADS TO PRO DUCTION OF RESP &/NUISANCE (SUP DAT)
Ventilation:WHERE ADEQUATE NATURAL VENTILATION IS NOT AVAILABLE PROVIDE
SUITABLE LOCAL EXHAUST VENTILATION.
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
SUITABLE PROT CLTHG TO MIN SKIN CONT. WHERE THERE IS A RISK (ING 2)
Work Hygienic Practices:WASH HANDS W/SOAP & WATER & USE HAND CREAM.
REMOVE CONTAM CLOTHING & WASH BEFORE REUSE.
Supplemental Safety and Health
FIRST AID PROC: INGEST: IF SWALLOWED, DO NOT INDUCE VOMIT. RINSE MOUTH
W/WATER & DRINK 1 CUP OF WATER EVERY 10 MIN FOR 30 MIN. CALL TAMPA
BAY REGIONAL POIS CTL (TEL. #1-800-282-3171) &/SEEK MED ADVICE .
RESP PROT: DUST, AN APPROP NIOSH APPRVD RESP SHOULD BE WORN.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>347F,>175C
Vapor Pres:0.22 @ 25C
Vapor Density:HVR/AIR
Spec Gravity:1.03
Solubility in Water:SLIGHT (0.1-1.0%)
Appearance and Odor:CLEAR LIQUID WITH AMMONICAL ODOR
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ACIDS, EPOXY RESINS AND ISOCYANATES.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:GASEOUS COMBINATIONS OF CARBON,
HYDROGEN, NITROGEN AND OXYGEN MAY OCCUR AT ELEVATED TEMPERATURES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:POTASSIUM IODIDE-IODATE REAGENT
CAGE:52454
CAGE:52454
============= Composition/Information on Ingredients =============
Ingred Name:DI WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: >10%
Ingred Name:POTASSIUM IODIDE
CAS:7681-11-0
RTECS #:TT2975000
Fraction by Wt: <1%
Ingred Name:POTASSIUM IODATE
CAS:7758-05-6
RTECS #:NN1350000
Fraction by Wt: <1%
Ingred Name:SODIUM BICARBONATE
CAS:144-55-8
RTECS #:VZ0950000
Fraction by Wt: <1%
===================== Hazards Identification =====================
Effects of Overexposure:SKIN/EYE:IRRITANT
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WATER 15 MIN,CONSULT MD.SKIN:FLUSH W/SOAP AND
WATER
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH W/WATER
======================Handling and Storage ======================
Handling and Storage Precautions:USE CARE IN HANDLING THIS PRODUCT AS
YOU WOULD ANY INDUSTRIAL CHEMICAL
============= Exposure Controls/Personal Protection =============
Ventilation:GENERAL
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F/100C
Spec Gravity:1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR COLORLESS LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW LOCAL,STATE AND FED REGS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:8048297 LAWN GREEN
CAGE:DO804
CAGE:DO804
CAGE:38360
============= Composition/Information on Ingredients =============
Ingred Name:DIETHYLENE GLYCOL BUTYL ETHER ACETATE, ETHANOL, 2-
(2-BUTOXYETHOXY), BUTYL CARBITOL ACETATE
CAS:124-17-4
RTECS #:KJ9275000
Fraction by Wt: 10-25%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MODERATE IRRITATION. SKIN:
SLIGHT IRRITATION. INHALATION: NASAL & RESPIRATORY IRRITATION, CNS
EFFECTS, DEATH. INGESTION: GI IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DIZZINESS, WEAKNESS, FATIGUE,
NAUSEA, HEADACHE, UNCONSCIOUSNESS, VOMITING, DIARRHEA, REDNESS,
TEARING.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER.
INHALATION: REMOVE TO FRESH AIR. INGESTION: IF CONSCIOUS GIVE 2
GLASSES OF WATER & INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point:237F
Extinguishing Media:DRY CHEMICAL, CO2, ALCOHOL FOAM.
Fire Fighting Procedures:WEAR A SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:VAPORS ARE >AIR & MAY TRAVEL ALONG GROUND
TO DISTANT IGNITION SOURCE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES. ABSORB MATERIAL
W/VERMICULITE/FLOOR ABSORBENT. DISPOSE OF CONTAMINATED MATERIALS
======================Handling and Storage ======================
Handling and Storage Precautions:FOR FLAMMABLE/COMBUSTIBLE PRODUCTS,
FOLLOW STORAGE & HANDLING GUIDELINES PRESENT IN NFPA 30 FLAMMABLE &
COMBUSTIBLE LIQUIDS CODE.
Other Precautions:CONTAINERS MAY BE HAZARDOUS WHEN EMPTIED, SINCE
EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES WHICH CAN GENERATE
VAPORS W/IN FLAMMABLE LIMITS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:SUFFICIENT TO MAINTAIN OPERATOR EXPOSURE <APPLICABLE
OCCUPATIONAL EXPOSURE STANDARDS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
USE OF A HAZARDOUS CHEMICAL MAY REQUIRE SUPPLEMENTAL VENTILATION FOR
PROTECTION OF PERSONNEL & FOR CONTROLLING FIRE/EXPLOSION HAZARD. A
QUALIFIED INDEPENDENT TESTING COMPANY CAN DETERMINE IF EXISTING
CONCENTRATIONS ARE W/IN ESTABLISHED RECOMMENDED/PERMISSIBLE
EXPOSURE LEVELS.
================== Physical/Chemical Properties ==================
Vapor Pres:<0.01
Evaporation Rate & Reference:(N-BU AC = 1): <0.01
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LAWN GREEN LIQUID/SEMI-SOLID INK W/MILD ODOR.
Percent Volatiles by Volume:15
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES/MINERAL ACIDS.
Stability Condition to Avoid:HEAT, FLAME & OTHER IGNITION SOURCES.
Hazardous Decomposition Products:CO & CO2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. IT'S THE RESPONSIBILITY OF THE GENERATOR OF THE WASTE
TO DETERMINE WHETHER THE WASTE GENERATED MEETS THE FEDERAL/STATE
HAZARDOUS WASTE CRITERIA.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SODIUM PERBORATE
CAGE:01VT8
CAGE:01VT8
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM PERBORATE (SODIUM PERBORATE, TETRAHYDRATE)
CAS:10486-00-7
RTECS #:SC7350000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS 1200 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CONTACT WITH SKIN AND EYE MAY
CAUSE IRRITATION. INHALATION MAY CAUSE RESPIRATORY IRRITATION. VERY
DANGEROUS WHEN INGESTED. CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:SKIN-IRRITATION. EYES-IRRITATION.
INHALED-RESPIRATORY IRRITATION. INGESTED-NONE SPECIFIED.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:IN ALL CASES GET MEDICAL ATTENTION. EYES-FLUSH WITH WATER FOR
15 MINUTES. SKIN-REMOVE CONTAMINATED CLOTHES. WASH WITH MILD SOAP &
WATER. INHALED-REMOVE TO FRESH AIR. ADMINISTER OXYGEN OR ARTIFICIAL
RE SPIRATION AS NEEDED. INGESTED-IF CONSCIOUS, GIVE WATER OR MILK
AND INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:NON-FLAMMABLE. DLA-HMIS: USE MEDIA APPROPRIATE FOR
SURROUNDING FIRE.
Fire Fighting Procedures:NONE. HMIS: WEAR SELF-CONTAINED BREATHING
APPARATUS AND FULL FIRE FIGHTER'S PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:USE APPROPRIATE TOOLS TO PUT IN APPROPRIATE
WASTE DISPOSAL CONTAINER. AVOID CONTACT WITH COMBUSTIBLE MATERIALS.
KEEP DAMP USING WATER SPRAY. PREVENT ENTRY INTO SEWERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, IGNITION SOURCES,
COMBUSTIBLE MATERIALS. STORE IN SEPARATE SAFETY STORAGE.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE
OR AN EMERGENCY OCCURS; WEAR AN MSHA/NIOSH APPROVED RESPIRATOR WITH
DUST CARTRIDGE OR AN AIR-SUPPLIED RESPIRATOR OR SCBA, AS REQUIRED.
USE IAW 29 CFR 19 10.134.
Ventilation:USE LOCAL EXHAUST TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:LAB COAT. DLA-HMIS: EYE WASH STATION &
SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
MSDS PRESENTED BY CAGE 01VT8 FOR CONTRACT SP0450-96-M-L901.
================== Physical/Chemical Properties ==================
HCC:D1
Appearance and Odor:WHITE, CRYSTALLINE POWDER; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:5114 EP GREASE
CAGE:72447
CAGE:29700
CAGE:72447
============= Composition/Information on Ingredients =============
Ingred Name:LITHIUM SOAP
Ingred Name:SYNTHETIC ESTERS
===================== Hazards Identification =====================
Effects of Overexposure:EYE/SKIN:IRRITATION. INJECTION OF GREASE INTO
SKIN: SOFT TISSUE DAMAGE.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH WITH WATER 15 MINUTES. SKIN: WASH WITH SOAP &
WATER. INJECTION UNDER SKIN: CONTACT PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:415F/212C (COC)
Lower Limits:1
Upper Limits:7
Extinguishing Media:FOAM,DRY CHEMICAL,CO*2,WATER FOG OR SPRAY.
Fire Fighting Procedures:SELF-CONT BREATH APP,WATER SPRAY TO COOL
EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:DO NOT MIX OR STORE WITH STRONG OXIDANTS.
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER FREE LUBRICAT. ADD ABSORBENT TO SPILL
AREA. KEEP PETROLEUM PRODUCTS OUT OF SEWERS & WATER COURSES BY
DIKING OR IMPOUNDING.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
DO NOT HANDLE OR STORE NEAR HEAT,SPARKS,FLAME OR STRONG OXIDANTS.
Other Precautions:AVOID BREATHING OIL MIST. LAUNDER OIL SOAKED CLOTHING
BEFORE REUSE. DISCARD LUBRICANT-SOAKED SHOES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN.
Ventilation:LOCAL
Other Protective Equipment:CHEM RESISTANT APRON,COVERALLS.
Supplemental Safety and Health
CONTAINER SIZE: 4 OZ TUBE
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:>500F/260C
Vapor Density:>10
Spec Gravity:0.94
Evaporation Rate & Reference:<0.01 (N-BUTY ACET
Solubility in Water:NEGLIGIBLE
Appearance and Odor:SMOOTH LIGHT TAN COLOR. MILD,BLAND ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS,EG: LIQUID CHLORINE,OXYGEN,CA(OCL)*2,NAOCL
Hazardous Decomposition Products:FUMES,SMOKE,CARBON MONOXIDE,SULFUR
OXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:ASSURE CONFORMITY WITH APPLICABLE DISPOSAL
REGULATIONS. DISPOSE OF ABSORBED MATERIAL AT AN APPROVED WASTE
DISPOSAL SITE OR FACILITY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SUPER HEAVY DUTY, MIL-C-2104C, GRADE 10
CAGE:OO165
CAGE:OO165
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM LUBE OIL
===================== Hazards Identification =====================
Effects of Overexposure:AVOID SKIN & EYE CONTACT
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & WATER. EYES: IMMED FLUSH W/WATER FOR AT
LEAST 15 MIN. CALL MD.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO*2, DRY CHEM, FOAM
Fire Fighting Procedures:ENCLOSED AREA, AIR-SUPP RESCUE EQUIP
Unusual Fire/Explosion Hazard:COOL FIRE EXPOSED CONTAINERS W/WATER. DO
NOT STORE OR MIX W/STRONG OXIDANTS.
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER FREE LIQUID. ADD ABSORBENT TO SPILL
AREA.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED. KEEP AWAY FROM
HEAT & OPEN FLAMES.
Other Precautions:AVOID PROLONGED OR REPEATED CONTACT W/SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF NEEDED, NIOSH/MSHA APPROVED RESP PROTECTION
Ventilation:LOCAL EXHAUST, NEEDED ONLY TO CAPTURE HOT FUMES
NEEDED
Supplemental Safety and Health
MFG ADDRESS: J D STREETT & CO, INC. 144 WELDON PKWY, MARYLAND HGTS, MO
63043.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:400+F
Spec Gravity:0.90
Appearance and Odor:MILD PETROLEUM ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS, LIKE LIQUID CHLORINE & CONCENTRATED OXYGEN
Hazardous Decomposition Products:CARBON MONOXIDE IN THE CASE OF
INCOMPLETE COMBUSTION
Conditions to Avoid Polymerization:MFG STATES NO POLYMERIZATION UNDER
MORM OPERATNG CONDITIONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATION UNDER CONTROLLED CONDITIONS.
DISPOSE IAW LOCAL, STATE, FED REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NITRIC ACID, A200S-500
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:NITRIC ACID (SARA 302/313) (CERCLA)
CAS:7697-37-2
RTECS #:QU5775000
Fraction by Wt: 69-71%
OSHA PEL:2 PPM
ACGIH TLV:2 PPM/4 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER LD50 (ORAL RAT): 90 ML/KG
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 29-31%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 2.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: NONE. ACUTE: EYE: SEV
EYE BURNS. MAY CAUSE IRREVERSIBLE EYE INJURY. SKIN: MAY CAUSE SEV
IRRIT. CAUSES SKIN BURNS. MAY CAUSE DEEP, PENETRATING ULCERS OF
SKIN. INGEST: GI TRACT BURNS. MAY CAUSE PERFORATION OF DIGESTIVE
TRACT. INHAL: MAY BE FATAL IF INHALED. EFTS MAY BE DELAYED. MAY
CAUSE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: IRRIT OF RESP TRACT W/BURNING PAIN IN
NOSE & THROAT, COUGHING, WHEEZING, SHORTNESS OF BRTH & PULM EDEMA.
CHRONIC: RPTD INHAL MAY CAUSE CHRONIC BRONCHITIS. REPEATED EXPOSURE
MAY CAUSE EROSION OF TEETH.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN, OCCAS
LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. DO NOT ALLOW VICTIM
TO RUB/KEEP EYES CLSD. SKIN: FLUSH W/PLENTY OF SOAP & WATER FOR AT
LEAST 15 MIN WHILE REMOVING CONTAM CLTHG & SHOES. GET MED AID IF
IRRIT DEVELOPS/PERSISTS. WASH CLTHG BEFORE REUSE. INGEST: DO NOT
INDUCE VOMIT & SEEK IMMED MED ADVICE. INHAL: REMOVE TO FRESH AIR
(SUP DAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:SUBSTANCE IS NON-COMBUSTIBLE; USE AGENT MOST
APPROPRIATE TO EXTINGUISH SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO KEEP FIRE-EXPOSED CONTAINERS COOL.
SUBSTANCE IS NON-COMBUSTIBLE.
Unusual Fire/Explosion Hazard:STRONG OXIDIZER. CONTACT WITH COMBUSTIBLE
MATERIALS MAY CAUSE A FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SPILL WITH INERT MATERIAL (E.G., DRY
SAND OR EARTH), THEN PLACE INTO A CHEMICAL WASTE CONTAINER. WEAR
NIOSH APPROVED SCBA & APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT
(SEE CONTROL MEASURES SECTI ON).
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION. DO NOT
GET IN EYES OR ON SKIN. DO NOT INGEST OR INHALE.
Other Precautions:STORE IN A COOL, DRY, WELL-VENTILATED AREA AWAY FROM
INCOMPATIBLE SUBSTANCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
29CFR 1910.134. ALWAYS USE A NIOSH APPROVED RESPIRATOR WHEN
NECESSARY.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
AIRBORNE CONCENTRATIONS BELOW THE PERMISSIBLE EXPOSURE LIMITS.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER . WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN
EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
Supplemental Safety and Health
MATLS TO AVOID: MATERIALS AND COMBUSTIBLES. FIRST AID PROC: IMMED. IF
NOT BRTHG, GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE OXYGEN. GET MED
AID. NOTES TO MD: TREAT SYMPTOMATICALLY & SUPPORTIVELY. NO SPEC
IFIC ANTIDOTE EXISTS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:187F,86C
Melt/Freeze Pt:M.P/F.P Text:-44F,-42C
Vapor Pres:6.8
Spec Gravity:1.50
pH:1.0
Solubility in Water:SOLUBLE
Appearance and Odor:TRANSPARENT, CLEAR OR YELLOWISH LIQUID. STRONG,
ACRID ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTS W/OVER 150 CHEMICAL COMBINATIONS. REFER TO NFPA FIRE PROT GUIDE
FOR SPECIFICS. REACTS VIOLENTLY W/ORG (SUP DAT)
Stability Condition to Avoid:HIGH TEMPS, INCOMPATIBLE MATERIALS,
MOISTURE, REDUCING AGENTS. DECOMPOSES WHEN IN CONTACT W/AIR,
LIGHT/ORGANIC MATTER.
Hazardous Decomposition Products:NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE, AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:600 INDUSTRIAL ENAMEL 11136
Preparer's Name:PATRICIA SHAW
CAGE:HO931
CAGE:3Z268
CAGE:HO931
============= Composition/Information on Ingredients =============
Ingred Name:HYDROCARBON MIXTURE (VAPOR PRESSURE 2.0 MM HG @ 68 F)
CAS:64741-41-9
Fraction by Wt: 30%
Other REC Limits:NONE SPECIFIED
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:SILICA, QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 0.11%
Other REC Limits:NONE SPECIFIED
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL: NASAL, RESP IRRIT. EYE: SEVERE
IRRIT. SKIN: PROLONG/REPEAT: MOD IRRIT, DEFATTING, DERMATITIS.
INGEST: DIGEST TRACT IRRIT, CENTRL NERV SYS DEPRESS. ASPIRATION
HZD. MAT'L CAN ENTER LUNGS DURING S WALLOW/VOMIT--CAUSE LUNG
INFLAMMATION. CHRONIC: RESPIR SYS, LUNGS, EYE, SKIN, GI TRACT,
LIVER, SPLEEN, KIDNEY DAMAGE.
Explanation of Carcinogenicity:CRYSTALLINE SILICA IS LISTED BY IARC AS
A CARCINOGEN. ACGIH HAS ASSIGNED TLV'S TO THIS MATERIAL.
Effects of Overexposure:INHAL: DIZZINESS, WEAKNESS, FATIGUE, NAUSEA AND
HEADACHE. HIGH CONCENTRATIONS MAY RESULT IN NARCOSIS (CENTRAL
NERVOUS SYSTEM DEPRESSION). EYE: TEARING, REDNESS, AND BLURRED
VISION.
Medical Cond Aggravated by Exposure:RESPIRATORY TRACT IRRITATION,
DERMATITIS, AND NAUSEA.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/WATER 15 MIN, LIFTING EYELID. GET MED AID. SKIN:
REMOVE CONTAM CLOTHING, WASH W/SOAP & WATER. IF IRRIT PERSISTS, SEE
DR. INHAL: REMOVE TO FRESH AIR. APPLY ARTIF RESPIRATION OR ADMIN
OXYGE N IF NEEDED. SEE DR. INGEST: GIVE WATER/MILK TO DRINK &
BY MED PERSONNEL. IF MED ADVICE UNAVAILABLE, TAKE TO NEAREST EMERG
HOSPITAL.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:104F,40C
Lower Limits:1.0
Upper Limits:6.1
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE EXTINGUISHERS (NFPA FLAMM LIQ). WATER MAY
BE INEFFECTIVE BUT MAY BE USED AS FOG FOR COOLING. FIRE FIGHTERS
SHOULD WEAR FULL PROTECT CLOTH & BREATHING APP.
Unusual Fire/Explosion Hazard:VAPOR FORM EXPLOSIVE MIX W/AIR (LEL TO
UEL), CAN BE IGNITED BY MANY SOURCES. CLOSED CNTNRS MAY EXPLODE
W/HEAT. ISOLATE FROM HEAT/IGNITION SOURCES.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE
ALL IGNITION SOURCES. VENTILATE THE AREA. PROVIDE APPROPRIATE
PROTECTIVE EQUIPMENT. DIKE AROUND THE SPILL AREA. COVER SPILL WITH
INERT ABSORBENT AND TRANSF ER USING NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 80F IN CLOSED CONTAINER.
STORE IN ORIGINAL CONTAINER. AVOID FLAME & HIGH TEMPERATURES. DO
NOT STORE NEAR OXIDIZING AGENTS OR ACIDS.
Other Precautions:VAPOR IS HEAVIER THAN AIR, MAY TRAVEL DISTANCE TO
IGNIT SOURCE & FLASHBACK. DON'T INGEST. AVOID INHAL OF HEATED
VAPOR/SPRAY MIST. KEEP FROM HEAT. GROUND CONNECTIONS, CONTAINERS
WHEN POURING TO MINIMIZ E STATIC ELEC. USE NON-SPARKING TOOLS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA EQUIP WHEN AIRBORN EXPOSURE
EXCEEDS TLV. CONSULT RESPIRATOR MFR TO DETERMINE EQUIPMENT FOR
GIVEN APPLICATION. HIGH AIRBORN CONCENTRATIONS MAY REQUIRE USE OF
SUPPLIED-AIR RESPIRATOR OR S ELF-CONTAINED BREATHING APPARATUS.
Ventilation:PROVIDE SUFFICIENT VENT TO CONTROL EXPOSURE LEVELS BELOW
TLV/ PEL. VENTILATION EQUIPMENT MUST BE EXPLOSION PROOF.
Other Protective Equipment:WEAR IMPERMEABLE APRONS & PROTECT CLOTH WHEN
POSSIBLE TO PREVENT SKIN CONTACT. HEAD CAP WHEN POSSIBLE STRONGLY
RECOMMEND
Work Hygienic Practices:AFTER USING, WASH BEFORE EATING, TOILETING OR
SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:315F,157C
Vapor Density:> AIR
Spec Gravity:1.0 (WATER=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NOT WATER SOLUBLE
Appearance and Odor:PIGMENTED LIQUID. SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:DO NOT EXPOSE TO HEAT OR IGNITION SOURCES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
DIOXIDE AND/OR MONOXIDE, LOW MOLECULAR WEIGHT HYDROCARBONS AND
ORGANIC ACIDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP OUT OF DRAINS, SEWERS, AND WATERWAYS.
DISPOSE OF PRODUCT IN ACCORDANCE WITH FEDERAL, STATE & LOCAL
REGULATIONS. IGNITABLE D001.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1208A
CAGE:DO828
CAGE:DO828
CAGE:94058
============= Composition/Information on Ingredients =============
Ingred Name:METHYLENE CHLORIDE(SARA III)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 48%
OSHA PEL:500 PPM/C,1000; Z2
ACGIH TLV:50 PPM, A2; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:O-CRESOL
Fraction by Wt: 28%
ACGIH TLV:S, 5PPM
Ingred Name:POTASSIUM SALT OF TALL OIL FATTY ACID
Fraction by Wt: 10.5%
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 9.5%
OSHA PEL:350 PPM/450 STEL
ACGIH TLV:350 PPM/450STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 0.6%
OSHA PEL:C, 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:EYES:IRRIT. INHAL:DROWSINESS VERTIGO, HEADACHE.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH IMMED W/ WATER FOR 15 MINUTES. SKIN: WASH W/ SOAP
AND WATER. INGEST:GIVE WATER, INDUCE VOMIT. INHAL: REMOVE TO FRESH
AIR, ADMINISTER ARTIFICIAL RESPIRATION IF NECESSARY.
===================== Fire Fighting Measures =====================
Flash Point:>212F; 100C(TCC)
Extinguishing Media:CO*2, DRY POWDER
Fire Fighting Procedures:SCBA
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB ON SOLID ABSORBENT
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE NEAR HEAT SOURCE. KEEP
COVERED.
Other Precautions:DO NOT BRAZE, WELD OR FLAME CUT WITH OUT PROPER RESP
DEVICE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MFR RECMS NIOSH/MSHA APPRVD MASK FOR ORGANIC
VAPORS.
Ventilation:MECHANICAL(GENERAL) SUFFICIENT TO KEEP BELOW TLV.
Other Protective Equipment:RUBBER APRON
Supplemental Safety and Health
SPEC:TYPE I. INGREDIENTS:WATER-3%. CONTAINER SIZE: 5 GAL CAN.
================== Physical/Chemical Properties ==================
HCC:T4
Boiling Pt:B.P. Text:100F; 38C
Vapor Pres:340
Vapor Density:3.25
Spec Gravity:1.18
Solubility in Water:INSOLUBLE
Appearance and Odor:BROWN LIQUID, PHENILIC ODOR.
Percent Volatiles by Volume:60
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:DO NOT HEAT
Hazardous Decomposition Products:CO*2, HYDROGEN CHLORIDE IF IGNITED
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IAW FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ETHYLENE GLYCOL, 99+%, 29323-7 (SUPP DATA)
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA III)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 99%+
OSHA PEL:C 50 PPM
ACGIH TLV:C 50 PPM,VAPOR; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE SUPP DATA
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: HARMFUL IF SWALLOWED, INHALED,
ABSORBED THRU SKIN. VAP/MIST IS IRRITATING TO THE EYES, MUC MEMBS &
UPPER RESP TRACT. CAUSES SKIN IRRITATION. MAY CAUSE NERV SYS
DISTURB. PRLNG EXPOSURE CAN CAUSE : NAUSEA, HEADACHE & VOMITING.
CHRONIC:MAY CAUSE REPRO DISORDERS. TARGET ORGANS: LIVER, KIDNEYS.
(SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:INGEST: EARLY SYMPS MIMIC ALCOHOL INEBRIATION,
FOLLOWED BY NAUS, VOMIT, ABDOM PAIN, WEAK, MUSC SORE, RESP FAILURE,
CONVL, CVS COLLAPSE, PULM EDEMA, HYPOCALCEMIC TENANY & SEV
METABOLIC ACIDOSIS. W/O TR TMT, DEATH MAY OCCUR IN 8-24 HRS.
SURVIVORS OF INITIAL TOX PERIOD USUALLY DEVELOP RENAL FAILURE ALONG
W/BRAIN/LIVER DMG.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF WATER
FOR AT LEAST 15 MINUTES WHILE REMOVING CONTAMINATED CLOTHING AND
SHOES. INHAL: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRA TION. IF BREATHING IS DIFFICULT, GIVE OXYGEN.
CALL MD. WASH CONTAMINATED CLOTHING BEFORE REUSE. INGEST: CALL MD
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>230F,>110C
Lower Limits:3.2%
Upper Limits:15.3%
Extinguishing Media:WATER SPRAY, CO*2, DRY CHEMICAL POWDER, ALCOHOL OR
POLYMER FOAM
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT TO PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH/MSHA APPROVED RESPIRATOR, CHEMICAL
OR VERMICULITE AND PLACE IN CLOSED CONTAINERS FOR DISPOSAL.
VENTILATE AREA AND WASH SP ILL SITE AFTER MATERIAL PICKUP IS
COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:TOXIC. DO NOT BREATHE VAPOR. KEEP
TIGHTLY CLOSED. HYGROSCOPIC. STORE IN A COOL, DRY PLACE.
Other Precautions:IRRITANT. REPRODUCTIVE HAZARD. AVOID CONTACT WITH
EYES, SKIN AND CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:RUBBER BOOTS AND OTHER PROTECTIVE CLOTHING,
SAFETY SHOWER AND EYE BATH
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER USE AND BEFORE
EATING, DRINKING, SMOKING OR USING SANITARY FACILITIES .
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO: SPECTROPHOTOMETRIC GRADE. LD50-LC50 MIX:
LD50: (ORL/RAT)=4700 MG/KG, (IPR/RAT)=5010 MG/KG, (SCU/RAT)=2800
MG/KG, (IVN/RAT)=3260 MG/KG, (ORL/MUS)=7500 MG/KG, (IPR/MUS)=5614
MG /KG, (IVN/MUS)=3000 MG/KG, (ORL/DOG)=5500 MG/KG, (ORL/CAT)=1650
MG/KG, (SKN/RBT)=9530 MG/KG, (ORL/GPG)=6610 MG/KG.
================== Physical/Chemical Properties ==================
HCC:T4
Boiling Pt:B.P. Text:385F,196C
Melt/Freeze Pt:M.P/F.P Text:9F,-13C
Vapor Pres:0.08 @ 20C
Vapor Density:2.1
Spec Gravity:1.113
Solubility in Water:SOLUBLE
Appearance and Odor:COLORLESS LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG BASES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CO, CO*2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE OR MIX THE MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. DISPOSE I/A/W FEDERAL, STATE AND LOCAL
LAWS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SOFT & BEAUTIFUL DEEP CONDITIONER NO LYE CR
CAGE:DO898
CAGE:DO898
============= Composition/Information on Ingredients =============
Ingred Name:NON HAZARDOUS INGREDIENT
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXCESSIVE SKIN AND EYE CONTACT COULD
CAUSE IRRITATION.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:MAY CAUSE EYE, SKIN IRRITATION.
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH COPIOUS AMOUNT OF WATER. IF IRRITATION
PERSISTS, CONSULT A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F,>93C
Lower Limits:ND
Upper Limits:ND
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:THE PRODUCT IS A THICK CREME, RECOVER AS MUCH
AS POSSIBLE. SMALL AMOUNTS CAN BE FLUSHED INTO THE MUNICIPAL SEWAGE
SYSTEM.
======================Handling and Storage ======================
Handling and Storage Precautions:STANDARD GOOD HOUSEKEEPING PROCEDURES.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NA
Ventilation:NA
Other Protective Equipment:NA
Work Hygienic Practices:WASH WITH SOAP AND RINSE WITH WATER.
Supplemental Safety and Health
NA
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>200F,>93C
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:ND
Vapor Density:ND
Spec Gravity:ND
Evaporation Rate & Reference:NA
Solubility in Water:APPRECIABLE
Appearance and Odor:THICK OFF-WHITE CREME WITH A FAINT FLORAL SMELL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL OF WASTE SHALL COMPLY WITH LOCAL, STATE
AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ALIPHATIC ISOCYANATE CAT,ELASTOMERIC #09BR001CAT
Kit Part:Y
Preparer's Name:NORM GAUL
CAGE:5M511
CAGE:33461
CAGE:5M511
============= Composition/Information on Ingredients =============
Ingred Name:ALAPHATIC ISOCYONATE
CAS:4035-89-6
Fraction by Wt: 45.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT EST.
ACGIH TLV:NOT EST.
Ingred Name:HEXAMETHYLENE DIISOCYANATEFREE MONOMER CONTENT
<0.5(RESINSOLIDS@TIMEOFMFG) AFTER 3 MONTHS MAY TO MAX OF 1.6
(CERCLA).
CAS:822-06-0
RTECS #:MO1740000
Other REC Limits:C = 0.02 PPM MILES
ACGIH TLV:0.005 PPM; TWA
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:N-BUTYL ACETATE (CERCLA) VP = 13 @ 68F
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: <5.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:150 PPM 200/STEL
ACGIH TLV:150 PPM/200STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ISOBUTYL KETONE VP = 15 @ 68F (SARA 313) (CERCLA)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 30.74%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:50 PPM/75 STEL
ACGIH TLV:50 PPM/75 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE VP 70 @68F (SARA 313) (CERCLA)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 19.2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE; VAPORS IRRIT EYES, NOSE, THROAT
& ACUTE NERV SYS DEPRESSON. INHAL:HEADACHES, DIZZINESS, STAGGERING,
DIFFICULT BREATHING, CONFUSION, UNCONSCIOUSNESS, COMA. SKIN: IRRIT
(SWELLING, REDNESS, RASH).MAY CAUSE DEFATTING/CRACKING. EYES:
IRRIT (TEARING, REDNESS, SWELLING W/STINGING). INGEST: IRRIT
POSSIBLE COROSION TO*
Explanation of Carcinogenicity:NK *MOUTH/STOMACHE TISSUE/DIGESTIVE
TRACT. VOMITING MAY CAUSE ASPIRATION OF SOLVENT CAN CAUSE CHEMICAL
PNEUMINITIS.
Effects of Overexposure:CHRONIC; AS A RESULT OF PREVIOUS REPEATED
OVEREXPOSURE OR A SINGLE LARGE DOSE, CERTAIN INDIVIDUALS WILL
DEVELOP ISOCYANATE SENSITIZATION WHICH WILL CAUSE THEM TO REACT TO
A LATER EXPOSURE OF ISOCYANAT E LEVELS WELL BELOW THE TLV VALUE OF
ISOCYANATES.
Medical Cond Aggravated by Exposure:ASTHMA AND ANY OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA AND DERMATITIS. ISOCYANATE
SENSITIZATION.
======================= First Aid Measures =======================
First Aid:INHAL: MOVE TO FRESH AIR. RESTORE BREATHING. ASTHMATIC TYPE
SYMPTOMS MAY DEVELOP (IMMED/DELAYED). GET MED AID. SKIN: REMOVE
CONTAMINATED CLOTHING. WASH AFFECTED AREAS WITH SOAP & WATER. WASH
CONTAMINA TED CLOTHES BEFORE REUSE. EYES: FLUSH WITH LUKEWARM WATER
(LOW PRESSURE) AT LEAST 15MIN. LIFTING EYELIDS. GET MED AID.
INGEST: DO NOT INDUCE VOMITING. DO NOT GIVE ANYTHING TO
UNCONSCIOUS. GET MED AID.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:76.0F,24.4C
Lower Limits:1.05
Upper Limits:7.60
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG,
WATER SPRAY.
Fire Fighting Procedures:USE FULL PROTECT CLOTHING FIREFIGHTING
EQUIPMENT W/SCBA. WATER MAY BE USED TO COOL CLSD CNTNRS (PREVENT
PRESSURE BILDUP/AUTOIGNITION/EXPLOSION).
Unusual Fire/Explosion Hazard:KEEP CNTNR CLSD. KEEP FROM HEAT/IGNIT
SOURCE. CLSD CNTNR MAY EXPLODE W/HEAT. APPLIC TO HOT SURFACE REQ
SPECIAL PRECAUTION. OVEREXPOSURE TO DECOMP PROD-HLTH HZD.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE
ALL SOURCES OF IGNITION (FLAME, SPARK SOURCES, HOT SURFACES).
VENTILATE AREA. CONTAIN AND REMOVE WITH INERT ABSORBENT AND
NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN BUILDINGS IN COMPLIANCE WITH
OSHA 1910.106. AVOID STORING NEAR HIGH TEMPS/IGNITION SOURCE. STORE
IN CLOSED CONTAINER IN WELL VENTILATED AREA.
Other Precautions:KEEP CNTNR TIGHT/UPRIGHT (PREVENT LEAK). PREVENT
PROLONGD VAPOR BREATHING. PROLONGD OVEREXPOSURE MAY CAUSE ALLERGIC
REACTION. AVOID SKIN/EYE CONTACT. DONT INGEST.DONT HANDLE TILL MFR
PRECAUTIONS READ/ UNDERSTOOD. SMOKE IN SMOKING AREAS ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESP REC FOR USE IN ORGANIC VAPOR
ENVIRONMENT (AIR PURIFYING/FRESH AIR SUPPLIED). OBSERVE OSHA
RESPIRATOR REGS. VAPOR PARTICULATE RESPIRATOR (TC23C) MAY BE USED
WHEN AIR MONITORING SHOWS VAPOR LEV ELS BELOW 10X TLV/PEL.
Ventilation:EXHAUST VENTILATION TO KEEP AIRBORNE CONCENTRATION (HDI,
POLYISOCYANATES, SOLVENT) BELOW TLVS. REMOVE IGNITION SOURCES.
Other Protective Equipment:THE USE OF LONG SLEEVE AND LONG LEG CLOTHING
RECOMMENDED. REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING OR USING
WASHROOM.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:175 TO 428F
Vapor Density:>AIR
Spec Gravity:0.92797
VOC Pounds/Gallon:492
pH:NA
Evaporation Rate & Reference:2.46 (BUAC)
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER LIQUID W/SOLVENT OROR
Percent Volatiles by Volume:61.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, AMINES, STRONG BASES, ALCOHOLS, METAL COMPOUNDS AND SURFACE
ACTIVE MATERIALS.
Stability Condition to Avoid:CONTACT WITH MOISTURE, MATERIAL WHICH
REACT WITH ISOCYANATES AND HIGH TEMPERATURES.
Hazardous Decomposition Products:BY HIGH HEAT/TEMPERATURE: CARBON
MONOXIDE, CARBON DIOXIDE, AND OXIDES OF NITROGEN, TRACES OF HCN AND
HDI.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE &
LOCAL ENVIRONMENTAL CONTROL REGULATIONS. EMPTY CONTAINERS MUST BE
HANDLED WITH CARE, DUE TO PRODUCT RESIDUE & FLAMMABLE VAPOR. DONT
INCINERATE CLOSED CONTAI NER. EPA HZD WASTE #: D001, F003,
F005,IGNITABLE.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:POTASSIUM SODIUM ALLOY, 3N5 (78:22), 19-1910
CAGE:JO672
CAGE:JO672
CAGE:3H269
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM SODIUM ALLOY; (TITLE COMPOUND)
CAS:11135-81-2
RTECS #:TT5790000
Fraction by Wt: 78%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM (CERCLA)
CAS:7440-23-5
RTECS #:VY0686000
Fraction by Wt: 22%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT WITH SKIN CAN CAUSE SEVERE
CHEMICAL BURNS. SODIUM IS HIGHLY REACTIVE, ESPECIALLY WITH
MOISTURE. EXTREMELY CORROSIVE TO TISSUE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH THE EYES WITH WATER FOR AT LEAST 15
MINUTES. SKIN: WASH THE AFFECTED AREA WITH SOAP AND WATER FOR AT
LEAST 5 MINUTES. INHAL: REMOVE THE VICTIM TO FRESH AIR AND SEEK
MEDICAL ATT ENTION IF COUGHING, SHORTNESS OF BREATHOR IRRITATION
PERSISTS. INGEST: GIVE THE VICTIM PLENTY OF WATER AND SEEK
IMMEDIATE MEDICAL ASSISTANCE.
===================== Fire Fighting Measures =====================
Flash Point:PYROPHORIC
Extinguishing Media:DRY POWDER ONLY.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
HIGHLY FLAMM. MATL READILY IGNITED W/FLAME, SPARKS, FRICTION/HEAT.
BURNING MATL MAY RELS TOX & CORROSIVE FUMES.
Unusual Fire/Explosion Hazard:PYROPHORIC MATERIAL. MATERIAL MAY IGNITE
SPONTANEOUSLY ON CONTACT WITH AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:THE MATERIAL WILL IGNITE SPONTANEOUSLY IN AIR.
BURNING MATERIAL MAY RELEASE TOXIC FUMES. LEAVE THE AREA UNLESS
FITTED WITH A NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS.
SMOTHER FIRE WITH DRY PO WDER. DO NOT USE WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE AND STORE THE MATERIAL UNDER AN
INERT ATMOSPHERE OF NITROGEN OR ARGON. KEEP AWAY FROM HEAT.
Other Precautions:THE MATERIAL WILL REACT WITH AIR AND MOISTURE. HANDLE
AND STORE THE MATERIAL UNDER AN INERT ATMOSPHERE OF NITROGEN OR
ARGON.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL RESPIRATION EQUIPMENT REQUIRED. NIOSH
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . LAB APRON.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MATLS TO AVOID: COMPOUNDS AND CARBON DIOXIDE. EYE PROT: AND FULL LENGTH
FACESHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:1445F,785C
Melt/Freeze Pt:M.P/F.P Text:9F,-13C
Spec Gravity:0.855
Solubility in Water:REACTS VIOLENTLY
Appearance and Odor:LIQUID METAL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, AIR, OXIDIZERS, HALOGENS, SULFUR, PHOSPHORUS, CARBON, ALCOHOLS,
HALOGENATED HYDROCARBONS, CARBONYL (SUPDAT)
Stability Condition to Avoid:CONTACT WITH AIR OR MOISTURE. MATERIAL
REACTS EXPLOSIVELY WITH WATER. EXPOSURE TO AIR CAN FORM EXPLOSIVE
SUPEROXIDES.
Hazardous Decomposition Products:POTASSIUM OXIDE, POTASSIUM SUPEROXIDE
AND SODIUM OXIDE (WHEN BURNED IN AIR).
==================== Disposal Considerations ====================
Waste Disposal Methods:MATERIAL SHOULD BE DISPOSED OF IN ACCORDANCE
WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HYSOL EA 9446 5 GAL SYSTEM, AS9329019
Kit Part:Y
Preparer's Name:MSDS DEPT
CAGE:33564
CAGE:33564
CAGE:3D523
============= Composition/Information on Ingredients =============
Ingred Name:ANILINE OLIGOMER (ORAL RAT LD50 2.4 G/KG)
CAS:9003-37-6
Fraction by Wt: 60-100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:MIXTURE HAS NOT BEEN TESTED AS A WHOLE.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IMMEDIATE EFFECTS: NONE NOTED ALTHOUGH
SLIGHTLY TOXIC BY INGESTION. LONG-TERM: NONE NOTED.
Explanation of Carcinogenicity:THIS COMPONENT IS NOT CONSIDERED A
CARCINOGEN.
Effects of Overexposure:NO SIGNIFICANT EFFECTS HAVE BEEN NOTED
W/LONG-TERM USE.
Medical Cond Aggravated by Exposure:NONE NOTED
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WATER FOR 15MINS. IF IRRIT PERSISTS GET MED ATTN.
SKIN:WASH THOROUGHLY W/SOAP & WATER. IF IRRIT PERSISTS GET MED
ATTN. INHAL:REMOVE VICTIM TO FRESH AIR. IF SYMPTOMS PERSIST GET MED
ATTN. I NGEST:DRINK PLENTY OF WATER. GET MED ATTN IMMED.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:302F,150C
Lower Limits:NOT TESTED
Upper Limits:NOT TESTED
Extinguishing Media:DRY CHEMICAL, OR HALON FIRE EXTINGUISHER, OR WATER
SPRAY, FOAM OR FOG.
Fire Fighting Procedures:WEAR SCBA & FULL PROTECTIVE CLOTHING, SUCH AS
TURN-OUT GEAR. CARTRIDGE RESP DO NOT PROVIDE ADEQUATE PROTECTION
FOR FIREFIGHTERS OR EXOTHERM MITIGATION.
Unusual Fire/Explosion Hazard:MAY LIBERATE LARGE QUANTITIES OF DENSE
FOUL-SMELLING SMOKE WHICH MAY CONTAIN UNIDENTIFIED TOXIC GASES.
================== Accidental Release Measures ==================
GLASSES. SCRAPE UP OR SHOVEL INTO DOT APPROVED WASTE CONTAINERS.
ABSORB W/SORBENT MATERIAL SUCH AS VERMICULITE OR SAND.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM SOURCES OF DIRECT HEAT
IN A DRY AREA. KEEP CONTAINER CLOSED WHEN NOT USING. THIS PRODUCT
MAY BE STORED @ 40F FOR UP TO 12 MONTHS.
Other Precautions:FOLLOW CURING SCHEDULE AS RECOMMENDED IN PRODUCT
LITERATURE.DON'T CUT/GRIND/WELD/DRILL ON/NEAR CONTAINER.AVOID
MIXING PARTS A&B IN BATCHES >1LB UNLESS PLAN TO USE IMMED.DON'T
HEAT MIXED ADHESIVE >75F UNLESS CURING SURFACES TO BE BONDED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:UNNECESSARY WITH ADEQUATE EXHAUST VENTILATION.
Ventilation:LOCAL EXHAUST VENTILATION AT THE POINT OF USE.
Other Protective Equipment:AN EYEWASH AND SAFETY SHOWER SHOULD BE
NEARBY AND READY FOR USE.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING MATERIALS.
Supplemental Safety and Health
FAILURE TO OBSERVE PRECAUTIONS IN MIXING/HEATING MAY RESULT IN
EXCESSIVE HEAT BUILD-UP CAUSING AN EXOTHERM. THE EXOTHERM HAS
POTENTIAL FOR RELEASE OF TOXIC GASES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NOT TESTED
Decomp Temp:Decomp Text:UNTESTED
Vapor Pres:NOT TESTED
Vapor Density:NOT TESTED
Spec Gravity:0.97
Viscosity:*
Solubility in Water:INSOLUBLE
Appearance and Odor:RED-BROWN LIQUID, CHARACTERISTIC ODOR
Corrosion Rate:NA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG LEWIS OR MINERAL ACIDS.
Stability Condition to Avoid:DO NOT CONTAMINATE W/STRONG OXIDIZING
AGENTS.
Hazardous Decomposition Products:OXIDES OF CARBIN & NITROGEN UNDER
BURNING CONDITIONS.
Conditions to Avoid Polymerization:POLYMERIZATION NOT LIKELY
==================== Disposal Considerations ====================
Waste Disposal Methods:NOT RCRA HAZ WASTE.HOWEVER, INCINERATION IN EPA
APPROVED WASTE INCINERATOR IS PREFERRED.CHEM ADDITIONS/
PROCESSING/OTHERWISE ALTERING MATL MAY MAKE WASTE MANAGEMENT INFOR
HEREIN INCOMPLETE/INACCURATE/ INAPPROPRIATE.CONSULT STATE/LOC
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AROMATIC HYDROCARBON MIXTURE, 5404
CAGE:55371
CAGE:55371
============= Composition/Information on Ingredients =============
Ingred Name:BENZENE (AH002)
CAS:71-43-2
RTECS #:CY1400000
= Wt:16.7
Other REC Limits:N/K
OSHA PEL:see 1910.1028
OSHA STEL:N/K
ACGIH TLV:32 MG/M3;10 PPM
ACGIH STEL:N/K
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:TOLUENE (AH004) ON MIXTURE
CAS:108-88-3
RTECS #:XS5250000
= Wt:16.7
Other REC Limits:N/K
OSHA PEL:see Table Z-2
OSHA STEL:N/K
ACGIH TLV:188 MG/M3;50 PPM
ACGIH STEL:N/K
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYLBENZENE (AH006)
CAS:100-41-4
RTECS #:DA0700000
= Wt:16.7
Other REC Limits:N/K
OSHA PEL:435 MG/M3;100 PPM
OSHA STEL:N/K
ACGIH TLV:434 MG/M3;100 PPM
ACGIH STEL:543 MG/M3;125 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:O-XYLENE (AH008)
CAS:95-47-6
RTECS #:ZE2450000
= Wt:16.7
Other REC Limits:N/K
OSHA PEL:435 MG/M3;100 PPM
OSHA STEL:N/K
ACGIH TLV:434 MG/M3;100 PPM
ACGIH STEL:651 MG/M3;150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:M-XYLENE (AH010)
CAS:108-38-3
RTECS #:ZE2275000
= Wt:16.7
Other REC Limits:N/K
OSHA PEL:435 MG/M3;100 PPM
OSHA STEL:N/K
ACGIH TLV:434 MG/M3;100 PPM
ACGIH STEL:651 MG/M3;150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:P-XYLENE (AH012)
CAS:106-42-3
RTECS #:ZE2625000
= Wt:16.7
Other REC Limits:N/K
OSHA PEL:435 MG/M3;100 PPM
OSHA STEL:N/K
ACGIH TLV:434 MG/M3;100 PPM
ACGIH STEL:651 MG/M3;150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:THRESHOLD LIMIT VALUE: 1 PPM. EXPOSURE
EFFECTS: DIZZINESS, NAUSEA, INCOORDINATION, STUPOR AND
UNCONSCIOUSNESS. SUSPECTED CARCINOGEN AND NEOPLASTIC AGENT. TOLUENE
AND BENZENE APPEAR ON THE NAVY OCCUPAT IONAL CHEMICAL REPRODUCTIVE
HAZARDS LIST. SEEK CONSULTATION FROM APPROPRIATE HEALTH
PROFESSIONALS CONCERNING LATEST HAZARD LIST INFORMATION AND SAFE
HANDLING AND EXPOSURE INFORMATION .
Explanation of Carcinogenicity:BENZENE: IARC MONOGRAPHS, SUPPLEMENT,
VOLUME 7, PAGE 120, 1987: GROUP 1. NTP 8TH ANNUAL REPORT ON
CARCINOGENS, 1998: KNOWN TO BE HUMAN CARCINOGEN. OSHA REGULATED:
CFR 29 1910.1028. HUMAN: BLOOD.
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT
LEAST 15 MINUTES. SKIN: IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF
WATER AND WASH WITH SOAP. INHALATION: REMOVE TO FRESH AIR FOLLOWING
EXPOS URE. ADMINISTER OXYGEN OR ARTIFICIAL RESPIRATION AS REQUIRED.
INGESTION: DO NOT INDUCE VOMITING. SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:=-11.1C, 12.F
Lower Limits:1.3%
Upper Limits:7.9%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH APPROVED SELF-CONTAINED BREATHING
APPARATUS AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND MAY
TRAVEL ALONG THE GROUND AND BE IGNITED AT LOCATIONS DISTANT FROM
THE SOURCE. BURNS VIGOROUSLY AND EMITS ACRID FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB ON ABSORBENT MATERIAL. DESTROY BY
LIQUID INCINERATION. CONTAMINATED ABSORBENT MAY BE LANDFILLED.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT FROM IGNITION. STORE IN A
COOL, WELL VENTILATED AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED ORGANIC CHEMICAL CANISTER OR
SUPPLIED AIR.
Ventilation:LOCAL EXHAUST RECOMMENDED.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER . PROTECTIVE CLOTHING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:=80.C, 176.F
Vapor Pres:100 MMHG @ 26.1C
Vapor Density:2.77 AIR=1
Spec Gravity:0.884 (WATER=1)
Evaporation Rate & Reference:<1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS LIQUID; AROMATIC HYDROCARBON ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:CARBON MONOXIDE AND/OR CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS .
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BORDO MIX
CAGE:29057
CAGE:29057
============= Composition/Information on Ingredients =============
Ingred Name:CUPRIC SULFATE (SARA III)
CAS:7758-98-7
RTECS #:GL8800000
Fraction by Wt: 12.75%
OSHA PEL:1 MG CU/M3
ACGIH TLV:1 MG/M3
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:INERT INGREDIENTS (TYPE NOT SPECIFIED)
Fraction by Wt: 87.25%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: INFLAMMATION OF THE STOMACH
& INTESTINES.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INGESTION: INFLAMMATION OF THE STOMACH &
INTESTINES.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SKIN: WASH W/SOAP & WATER.
REMOVE CONTAMINATED CLOTHING. EYES: FLUSH W/RUNNING WATER FOR AT
LEAST 15 MINUTES. CALL A PHYSICIAN IMMEDIATELY. INGESTION: GIVE
EMETIC SYRU P OF IPECAC.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER
Fire Fighting Procedures:FIRE FIGHTERS SHOULD BE EQUIPPED W/SCBA.
Unusual Fire/Explosion Hazard:LOW LEVEL DUST EXPLOSION POSSIBLE IN A
DUST CLOUD.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. SWEEP UP
SPILLED MATERIAL & REUSE AS INTENDED OR PLACE IN WASTE CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM FOOD, FEED & SEED.
KEEP DRY. DON'T REPACK IN METAL CONTAINERS. AVOID BREATHING DUST.
Other Precautions:SHOWER & LAUNDER CLOTHING IMMEDIATELY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DUST MASK SUITABLE FOR ORGANIC VAPORS/DUSTS
Ventilation:LOCAL EXHAUST: PREFERABLE
Other Protective Equipment:CLEAN, BODY-COVERING CLOTHING
Work Hygienic Practices:SHOWER & LAUNDER CLOTHING IMMEDIATELY AFTER
HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:INSOLUBLE
Appearance and Odor:BRIGHT BLUE-COLORED POWDER, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BHC, CHLORDANE, DINITRO COMPOUNDS, DITHIOCARBAMATES
Stability Condition to Avoid:CORROSIVE TO METALS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF CONTAINERS IN ACCORDANCE WITH
LOCAL/STATE/FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MR-502Y (BASE AND CATALYST)
Kit Part:Y
Preparer's Name:P. MICHAEL PECK
CAGE:30256
Contract Num:SP0450-99-MND48
CAGE:1JAE1
Contract Num:SP0450-99-M-NF81
CAGE:30256
Contract Num:SP0450-99-M-NH14
CAGE:30256
============= Composition/Information on Ingredients =============
Ingred Name:BASE: CONSIST OF THE FOLLOWING FIVE INGREDIENTS.
Ingred Name:SILICONE FLUID WITH FILLERS
< Wt:38.
Ingred Name:DIMETHYLPOLYSILOXANES
CAS:63148-62-9
RTECS #:JT6484500
< Wt:39.
Ingred Name:LEAD CHROMATE (CHROME YELLOW MEDIUM)
CAS:7758-97-6
RTECS #:GB2975000
< Wt:5.
OSHA PEL:0.15 MG/M3 PB
ACGIH TLV:0.05 MG/M3 PB
Ingred Name:PETROLEUM HYDROCARBON DISTILLATE
CAS:64741-44-2
RTECS #:LX3296000
< Wt:21.
Ingred Name:IRON OXIDE (FE3O4)
CAS:1317-61-9
< Wt:1.
Ingred Name:CATALYST: CONSIST OF THE FOLLOWING TWO INGREDIENTS.
Ingred Name:DIBUTYLTIN DILAURATE
CAS:77-58-7
RTECS #:WH7000000
< Wt:.05
Ingred Name:TIN CARBOXYLATE
CAS:301-10-0
< Wt:.05
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.1 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN CONTACT IS NOT KNOWN TO CAUSE
IRRITATION. EYE CONTACT MAY CAUSE TRANSIENT IRRITATION. IF INHALED
REMOVE TO FRESH AIR AND CONSULT PHYSICIAN. IN CASE OF EYE CONTACT
FLUSH WITH WATER FOR 15 MINUTESS AND CONSULT PHYSICIAN. SKIN
:FLUSH WITH WATER. OBTAIN MEDICAL ATTENTION IF IRRITATION OCCURS.
INGESTION:DO NOT INDUCE VOMITING. CONSULT PHYSICIAN.
Explanation of Carcinogenicity:CHEMICAL/COMPONENT LISTED AS CARCINOGEN
OR POTENTIAL CARCINOGEN: NONE.
======================= First Aid Measures =======================
First Aid:INHALATION: IF OVERCOME BY EXPOSURE REMOVE TO FRESH AIR
IMMEDIATELY. GIVE OXYGEN /ARTIFICIAL RESPIRATION AS NEEDED.OBTAIN
EMERG MEDICAL ATTNENTION. PROMPT ATTENTION IS ESSENTIAL.
EYE:IMMEDIATELY RINS E WITH CLEAN WATER FOR 15-20 MINUTES. RETRACT
EYELIDS OFTEN. IRRITATION OCCURS OBTAIN EMERG MEDICAL ATTENTION.
SKIN:REMOVE CONTAM CLOTH AS NEEDED. WASH SKIN THOROUGHLY WITH MILD
SOAP AND WATER. STICKY USE WATERLESS CLEANER FIRST. INGESTION: IF
LARGE QUANTITY SWALLOWED, GIVE LUKE WARM WATER (PINT) IF VICTIM IS
COMPLETELY CONSCIOUS/ALERT. DONT INDUCE VOMIT DUE TO RISK OF LUNG
DAMAGE. OBTAIN EMERGENC Y MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:=129.4C, 265.F
Autoignition Temp:Autoignition Temp Text:NP
Lower Limits:NP
Upper Limits:NP
Extinguishing Media:DRY CHEMICAL, CO2,WATER SPRAY.
Fire Fighting Procedures:DO NOT ENTER FIRE AREA WITHOUT PROPER
PROTECTION. FIGHT FIRE FROM SAFE DISTANCE/PROTECTED LOCATION.HEAT
MAY BUILD PRESSURE/RUPTURE CLOSED CONTAINERS,SPREADING FIRE,
INCREASING RISK OF BURNS & INJURIES , USE WATER SPRAY/FOG FOR
COOLING. DRY CHEMICAL CO2 PERMISSIBLE. NOTIFY AUTHORITIES IF LIQUID
ENTERS SEWER/PUBLIC WATERS
Unusual Fire/Explosion Hazard:NONE. AVOID EXTREME HEAT OR FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:UTILIZE PERSONAL PROTECTIVE EQUIPMENT. LIMIT
ACCESS TO QUALIFIED PERSONAL. SOAK UP W/INERT SOLIDS. PLACE IN
LABELED, SEALED CONTAINER. PREVENT FLOW TO SEWERS. NOTIFY
FIRE/ENVIRONMENT AUTHORITIES. COVE R SLIPPERY SURFACES W/GRANULAR
SOLID.CONTAIN TO PREVENT ESCAPE INTO ENVIRONMENT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL DRY AREA. STORE ONLY IN
CLOSED CONTAINERS AWAY FROM IGNITION SOURCES. PRACTICE CAUTION.
AVOID EYE OR SKIN CONTACT.
Other Precautions:WASH THOROUGHLY AFTER HANDLING. KEEP CONTAINERS
CLOSED WHEN NOT IN USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NEEDED.
Ventilation:GENERAL.
Other Protective Equipment:NONE SHOULD BE NEEDED.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. KEEP CONTAINERS
CLOSED WHEN NOT IN USE.
Supplemental Safety and Health
COMMON NAME: MR-502Y. CHEMICAL FAMILY: MIXTURE. CHEMICAL NAME: MIXTURE.
TRADE NAME & SYNONYMS: MR-502Y. FORMULA: MIXTURE OF SILICONE &
PETROLEUM HYDROCARBON DISTILLATE.
================== Physical/Chemical Properties ==================
HCC:V5
Boiling Pt:>148.9C, 300.F
Melt/Freeze Pt:M.P/F.P Text:NP
Decomp Temp:Decomp Text:NP
Vapor Pres:1@ 20C
Vapor Density:NEG
Spec Gravity:1.0
pH:NP
Viscosity:NP
Evaporation Rate & Reference:<1, ETHYL ETHER=1
Solubility in Water:INSOLUBLE
Appearance and Odor:YELLOW, SLIGHT ODOR
Percent Volatiles by Volume:NEG AT 1 ATM
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
KETONES
Stability Condition to Avoid:EXCESS HEATING OVER LONG PERIODS WILL
DEGRADE MATERIAL.
Hazardous Decomposition Products:SILICONE DIOXIDE, CARBON DIOXIDE, AND
TRACES OF INCOMPLETELY BURNED CARBON PRODUCTS.
Conditions to Avoid Polymerization:WILL NOT OCCUR
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW RECOMMENDED CURING PROCEDURES. DISPOSE OF
COLLECTION OR CONTAINMENT MATERIALS IN A SUITABLE CONTAINER IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL LAWS.
===================== Regulatory Information =====================
Federal Regulatory Information:COMPONENTS OF THIS PRODUCT ARE INCLUDED
IN THE TSCA INVENTORY.
======================= Other Information =======================
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:NETCARE ANTISEPTIC LOTION HAND SOAP, 414-0885
CAGE:JO484
CAGE:JO484
CAGE:8D738
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE CONTACT SLIGHTLY IRRITATING.
INGESTION:MAY BE HARMFUL. INHALATION:NOT CONSIDERED A HAZARD.
CHRONIC:NONE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD . EYES:WASH
W/LARGE VOLUMES OF WATER FOR AT LEAST 15 MINUTES WHILE LIFTIN G
UPPER & LOWER EYELIDS & ROTATING EYEBALL. GET MEDICAL ATTENTION IF
IRRITATION PERSISTS. INGEST:GIVE LARGE VOLUMES OF WATER. DO NOT
INDUCE VOMITING. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:FIRE FIGHTERS SHOULD OBSERVE ALL
PRECAUTIONS THAT APPLY TO ANY FIRE WHERE CHEMICALS ARE STORED.
================== Accidental Release Measures ==================
Spill Release Procedures:IF PRODUCT LEAKS OR SPILLS - FLOOD AREA
W/WATER - MOP UP - DISPOSE TO SANITARY SEWER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE CONTAINERS TIGHTLY CLOSED & IN
AN UPRIGHT POSITION. DO NOT DESTROY OR DEFACE THE LABEL.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NONE REQUIRED.
Ventilation:NONE REQUIRED.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE REQUIRED.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:1.02 (H*2O=1)
pH:10.1
Solubility in Water:COMPLETE
Appearance and Odor:PINK LIQUID; ALMOND ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:ABIDE BY FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:A14 W 534 SNOWCAP WHITE SOLID COLOR ALKYD STAIN
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL, GLYCOL
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: <5%
Other REC Limits:10 MG/CUM
OSHA PEL:50 PPM
ACGIH TLV:C 127 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED (C10-C15 SATURATED
HYDROCARBONS 97%, C10 AROMATICS 3%) *95-4*
CAS:64742-47-8
RTECS #:OA5504000
Other REC Limits:200 PPM EXXON
Ingred Name:MEDIUM ALIPHATIC NAPHTHA (AROMATIC 100), PARAFFIN-NAPTHANES
MINERAL SPIRITS
CAS:64742-88-7
Other REC Limits:100 PPM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:TITANIUM DIOXIDE, TIO2 (SUSPECTED ANIMAL CARCINOGEN, IARC
GROUP 3) *95-4*
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 0-19%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF EYES, SKIN & RESPIRATORY
SYSTEM, CNS DEPRESSION & POSSIBLY DEATH. CRYSTALLINE SILICA-MAY
CAUSE LUNG DAMAGE (SILICOSIS) & POSSIBLY CANCER. PROLONGED
OVEREXPOSURE TO SOLVENTS MAY CAUSE ADV ERSE EFFECTS TO THE LIVER &
URINARY SYSTEMS. OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT BRAIN
& NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, UNCONSCIOUSNESS, HEADACHE,
DIZZINESS, NAUSEA, LOSS OF COORDINATION, REDNESS, ITCHING, BURNING
SENSATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. KEEP WARM
& QUIET. SKIN: WASH AREA THOROUGHLY W/SOAP & WATER. EYES: FLUSH
W/LARGE AMOUNTS OF WATER FOR 15 MINS. OBTAIN MEDICAL ATTENTION IN
ALL CASE S.
===================== Fire Fighting Measures =====================
Flash Point:103F
Lower Limits:1
Upper Limits:7
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT & SCBA. WATER
SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE. USE WATER TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM ANY IGNITION SOURCE. CLOSED CONTAINERS EXPOSED TO EXTREME HEAT
MAY EXPLODE. (SEE SUPP)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION. VENTILATE & REMOVE
W/INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT & OPEN FLAME. USE
APPROVED BONDING & GROUNDING PROCEDURES. KEEP CONTAINER TIGHTLY
CLOSED WHEN NOT IN USE. DON'T TAKE INTERNALLY.
Other Precautions:TRANSFER ONLY TO APPROVED CONTAINERS W/COMPLETE &
APPROPRIATE LABELING. KEEP OUT OF REACH OF CHILDREN. INTENTIONAL
MISUSE BY DELIBERATELY CONCENTRATING & INHALING THE CONTENTS CAN BE
HARMFUL/FATAL. AV OID BREATHING VAPOR & SPRAY MIST. (SUPP)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOSURE CAN'T BE CONTROLLED <
APPLICABLE LIMITS, WEAR A PROPERLY FITTED ORGANIC VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA. WHEN SANDING/ABRADING DRIED
FILM, WEAR A DUST/MIST RES PIRATOR APPROVED BY NIOSH/MSHA FOR DUST.
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF
MAINTAINED < APPLICABLE EXPOSURE LIMITS.
Other Protective Equipment:TO MINIMIZE EXPOSURE, USE VENTILATION &
PERSONAL PROTECTIVE EQUIPMENT.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE EXPLOSION CONT'D: APPLICATION TO HOT SURFACES REQUIRES SPECIAL
PRECAUTIONS. PRECAUTIONS CONT'D: AVOID CONTACT W/SKIN & EYES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:300-416F
Vapor Density:>1
Spec Gravity:0.82-1.8
VOC Grams/Liter:4.18
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:SNOWCAP WHITE SOLID ODOR
Percent Volatiles by Volume:29-90
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, ELECTRICAL EQUIPMENT, SPARKS, OPEN
FLAME & OTHER SOURCES OF IGNITION, HOT SURFACES.
Hazardous Decomposition Products:BY FIRE: CO2, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MAY BE HAZARDOUS UNDER THE RCRA & MUST BE
TESTED FOR IGNITABILITY TO DETERMINE THE APPLICABLE EPA HAZARDOUS
WASTE NUMBERS. INCINERATE IN APPROVED FACILITY. DON'T INCINERATE
CLOSED CONTAINERS. DI SPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS OVERALL COMPOSITION
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:140 SATIN ENAMEL - 2312 PRETTY PINK
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 13%
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 14%
Other REC Limits:1000 PPM
OSHA PEL:1800 MG/CUM
ACGIH TLV:1000 PPM
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 5%
Other REC Limits:375 MG/CUM
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 2%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 6%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE; DIMETHYL KETONE
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 38%
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL 3-ETHOXYPROPIONATE
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: 5%
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 5%
OSHA PEL:2 MG/CUM (RESP DUST)
ACGIH TLV:2 MG/CUM (RESP DUST)
Ingred Name:TITANIUM DIOXIDE, TIO2
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 4%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF EYES/SKIN/RESPIRATORY
SYSTEM. MAY CAUSE CNS DEPRESSION. OVEREXPOSURE MAY BE FATAL.
PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE ADVERSE EFFECTS TO
LIVER/URINARY/REPRODUCTIVE SYSTEM & PER MANENT BRAIN/NERVOUS SYSTEM
DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: HEADACHE, DIZZINESS, NAUSEA, & LOSS
OF COORDINATION, UNCONSCIOUSNESS & DEATH. EYES/SKIN: REDNESS,
ITCHING OR BURNING SENSATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. KEEP WARM
& QUIET. SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/PLENTY OF WATER
FOR 15 MINS. INGESTION: NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS P ERSON. DON'T INDUCE VOMITING. GIVE SEVERAL GLASSES OF
WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:<0F
Lower Limits:0.7%
Upper Limits:6%
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIP & SCBA. WATER SPRAY
MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE PREFERABLE.
USE WATER TO COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO
BUILD-UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:USE ONLY W/ADEQUATE VENTILATION.
CONTENTS ARE FLAMMABLE. KEEP AWAY FROM HEAT, SPARKS & OPEN FLAME.
KEEP AREA VENTILATED.KEEP CONTAINERS TIGHTLY CLOSED
Other Precautions:EXTINGUISH ALL FLAMES/PILOT LIGHTS/HEATERS. TURN OFF
STOVES, ELECTRIC TOOLS & APPLIANCES & OTHER IGNITION SOURCES.
CONSULT NFPA CODE. USE APPROVED BONDING/GROUNDING PROCEDURES. KEEP
CONTAINER CLOSED W HEN NOT IN USE. DON'T TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
TLV BY VENTILATION, USE A NIOSH/MSHA PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESPIRATOR. WHEN SANDING OR ABRADING FILM, USE A
NIOSH/MSHA DUST/MIST RES PIRATOR.
Ventilation:LOCAL EXHAUST: PREFERABLE. GENERAL EXHAUST: ACCEPTABLE IF
THE EXPOSURE TO HAZARDOUS INGREDIENTS IS KEPT BELOW TLV.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS AFTER USING. DON'T SMOKE.
Supplemental Safety and Health
TRANSFER ONLY TO APPROVED CONTAINERS W/COMPLETE & APPROPRIATE LABELING.
KEEP OUT OF REACH OF CHILDREN. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING & INHALING THE CONTENTS CAN BE HARMFUL OR FATAL.
AVOID BREATHING VAPOR & SPRAY MIST & CONTACT W/SKIN & EYES.
OVEREXPOSURE TO DECOMPOSITION PRODUCTS CAUSE HEALTH HAZARD.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:<0-395F
Vapor Density:>1
Evaporation Rate & Reference:FASTER THAN ETHER
Percent Volatiles by Volume:>75
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, HOT SURFACES OR
OTHER IGNITION SOURCES.
Hazardous Decomposition Products:CO2, CO, OXIDES OF METALS IN HAZARDOUS
INGREDIENTS SECTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MAY BE HAZARDOUS UNDER THE RCRA. TEST
WASTE FOR IGNITABILITY TO DETERMINE THE APPLICABLE EPA HAZARDOUS
WASTE NUMBERS. INCINERATE IN APPROVED FACILITY. DON'T INCINERATE
CLOSED CONTAINER. DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SANITEX Q.C.--REGULAR, 3026
CAGE:86938
CAGE:86938
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ALCOHOL
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 4%
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: CAN BE IRRITATING UPON
CONTACT. INHAL: SLIGHT EFFECT SINCE LOW VOLATILITY. INGEST:
IRRITATING TO THROAT AND STOMACH.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN: WASH WITH SOAP AND WATER. EYES: FLUSH IMMEDIATELY WITH
PLENTY OF WATER FOR AT LEAST 15 MIN. CONSULT PHYSICIAN. INHAL: MOVE
TO FRESH AIR. GIVE OXYGEN, IF NEEDED. SEE DOCTOR. INGEST: RINSE
MOUTH A ND GIVE PLENTY OF WATER, FOLLOWED BY MILK, EGG WHITE OR
GRUEL. DO NOT INDUCE VOMITING. IMMEDIATELY SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:142F,61C
Extinguishing Media:EXTINGUISHING MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:MOP UP WITH WATER OR ABSORB SPILL WITH AN
ABSORBENT MATERIAL. (I.E. SELIG'S AP ABSORBENT); PICK UP AND
DEPOSIT IN A SUITABLE WASTE COTAINER. FLUSH AREA THOROUGHLY WITH A
DETERGENT SOLUTION. RINSE AREA THOROUGHLY WITH CLEAN WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN. HARMFUL
IF SWALLOWED. AVOID CONTACT WITH SKIN AND EYES.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NO SPECIAL VENTILATION REQUIRED.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PH: (CONCENTRATE): 11.0, PH (USE DILUTION OF 1:64) 10.9.
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:215F,102C
Spec Gravity:0.974
pH:SUPDAT
Evaporation Rate & Reference:1
Solubility in Water:COMPLETE
Appearance and Odor:OPAQUE, BLUE-BLACK LIQUID, STRONG PLEASANT
FRAGRANCE.
Percent Volatiles by Volume:>90
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ANIONIC MATERIAL.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:CHECK LOCAL, STATE AND FEDERAL REGULATIONS PRIOR
TO DISPOSAL. PRODUCT IS NOT CONSIDERED A HAZARDOUS WASTE UNDER
RCRA. LIQUIDS MAY BE ABLE TO BE DISPOSED OF BY FLUSHING INTO
SANITARY SEWER WITH PLENTYOF WATER. NEUTRALIZATION OF PH MAY BE
REQUIRED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MACE CN
Preparer's Name:BERNIE GRANEY
CAGE:MACES
CAGE:MACES
============= Composition/Information on Ingredients =============
Ingred Name:A-CHLOROACETOPHENONE
CAS:532-27-4
RTECS #:AM6300000
Fraction by Wt: 1%
Other REC Limits:0.05 PPM
OSHA PEL:0.05 PPM
ACGIH TLV:0.05 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SEC-BUTANOL ALCOHOL
CAS:78-92-2
RTECS #:EO1750000
Fraction by Wt: 20%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:1,2-PROPANEDIOL (PROPYLENE GLYCOL)
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: 20%
Ingred Name:CARVENE; CYCLOHEXENE, 1-METHYL-4-(1-METHYLETHENYL), CITRUS
TERPENE, D-LIMONENE, P-MENTHADIENE
CAS:5989-27-5
RTECS #:GW6360000
Fraction by Wt: 20%
Ingred Name:DIPROPYLENE GLYCOL METHYL ETHER, DOWANOL DPM, DIPROPYLENE
GLYCOL MONOMETHYL ETHER
CAS:34590-94-8
RTECS #:JM1575000
Fraction by Wt: 30%
Other REC Limits:100 PPM
OSHA PEL:100 PPM SKIN
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION/BURNING
SENSATION TO LUNGS & RESPIRATORY SYSTEM. EYES: IRRITATION/BURNING
SENSATION. MAY CAUSE SUPERFICIAL KERATITIS & CONJUNCTIVITIS. SKIN:
LIQUID CAN CAUSE IRRITATION/ABSORPTI ON. INGESTION: LIQUID MAY
CAUSE IRRITATION/BURNING SENSATION TO DIGESTIVE SYSTEM.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, BURNING SENSATION, DIZZINESS,
NAUSEA
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT,
ADMINISTER OXYGEN/CPR IF NECESSARY. EYES: FLUSH W/COOL WATER FOR 15
MINS. SKIN: WASH W/COOL WATER & SOAP. INGESTION: DRINK A GLASS OF
WATER & INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:110F
Extinguishing Media:DRY CHEMICAL, CO2/WATER SPRAY
Fire Fighting Procedures:COOL CONTAINERS IF EXPOSED TO FIRE/HIGH HEAT.
Unusual Fire/Explosion Hazard:PRODUCT PACKAGED IN AEROSOL FORM MAY
CAUSE CONTAINERS TO BURST WHEN EXPOSED TO EXTREME HEAT. VAPORS ARE
>AIR & MAY TRAVEL ALONG GROUND & BE IGNITED BY IGNITION.
================== Accidental Release Measures ==================
Spill Release Procedures:EXTINGUISH ALL FLAMES, THEN SOAK UP MATERIAL
IN ABSORBANT MATERIAL & SHOVEL INTO WASTE CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:PACKAGED PRODUCT IS UNDER PRESSURE.
DON'T PUNCTURE, INCINERATE/STORE AT TEMPERATURES >130F.
Other Precautions:STRONGLY IRRITATING TO EYES, NOSE & SKIN. AVOID
INHALING VAPORS & CONTACT W/SKIN. AVOID ABSORPTION OF PRODUCT ON
CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CHEMICAL RESPIRATOR, NIOSH APPROVED.
Other Protective Equipment:SOLVENT RESISTANT TYPE CLOTHING W/FULL
JACKET.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:211-370F
Spec Gravity:1.07
Solubility in Water:SLIGHT
Appearance and Odor:CLEAR AMBER LIQUID W/AROMATIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:EXTREME HEAT, TEMPS >175F
Hazardous Decomposition Products:CO2, CO, VARIOUS HYDROCARBONS, SMALL
AMOUNTS OF PHOSGENE.
Conditions to Avoid Polymerization:EXTREME HEAT, TEMPS >175F.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS. UN1950.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ADHESIVE LCA-49/BA-5
Kit Part:Y
CAGE:99098
CAGE:99098
============= Composition/Information on Ingredients =============
Ingred Name:DGBA EPOXY RESINS
CAS:25068-38-6
RTECS #:SL6475000
Fraction by Wt: <35%
Other REC Limits:NONE RECOMMENDED
Ingred Name:LITHIUM ALUMINUM SILICATE
CAS:1302-66-5
RTECS #:OJ5580000
Fraction by Wt: >30%
Other REC Limits:30 MPCCF
ACGIH TLV:2 MG (AL)/M3
Ingred Name:CALCIUM CARBONATE
CAS:471-34-1
RTECS #:FF9335000
Fraction by Wt: >30%
Other REC Limits:30 MPPCF
OSHA PEL:15 MG/M3 TOTAL DUST
ACGIH TLV:10 MG/M3
Ingred Name:POLYGLYCOL ESTER [GLYCOLS, POLYETHYLENE, MONOOLEATE]
CAS:9004-96-0
RTECS #:MD0880000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:PHENYL GLYCIDYL ETHER (PGE)
CAS:122-60-1
RTECS #:TZ3675000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 PPM
ACGIH TLV:1 PPM; 9394
Ingred Name:N-AMINO AMINOETHYL IMIDAZOLE & ISOMERIC ANALOGS
Fraction by Wt: 4%
Other REC Limits:NONE RECOMMENDED
Ingred Name:CHROME-COBALT-ALUMINUM-MAGNESIUM OXIDE PIGMENT
CAS:1345-16-0
Fraction by Wt: 0.06%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG/M3 (CO DUST)
ACGIH TLV:0.1 MG/M3 (CO DUST)
Ingred Name:EPICHLOROHYDRIN (SARA III)
CAS:106-89-8
RTECS #:TX4900000
Fraction by Wt: 0.06%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S, 5 PPM
ACGIH TLV:S, 2 PPM; 9394
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SKIN OR EYE IRRITATION
AND/OR SENSITIZATION AFTER REPEATED CONTACT.
Explanation of Carcinogenicity:EPICHLORHYDRIN IS LISTED BY NTP (AC) AND
IARC (2A) AS A SUSPECTED CARCINOGEN.
Effects of Overexposure:EYES:REDNESS, BLURRED VISION, TEARING. SKIN:
REDNESS, SWELLING, ITCHING/DISCOMFORT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN-WASH IMMEDIATELY WITH SOAP AND WATER. EYES-FLUSH WITH
PLENT OF WATER FOR AT LEAST 15 MINUTES. SEEK IMMEDIATE MEDICAL
ATTENTION. DLA-HMIS: INGESTED: GET MEDICAL ATTENTION. INHALED:
REMOVE TO FRESH AIR. GET MEDICAL ATTENTION IF
SYMPTOMSPERSIST/OCCUR.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:200F,93C
Extinguishing Media:WATER SPRAY, DRY CHENICAL, FOAM OR CARBON DIOXIDE.
TREAT AS CLASS B FIRE.
Fire Fighting Procedures:NONE. AVOID BREATHING SMOKE. WEAR
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE. KEEP NON-IGNITED MATERIAL COOL WITH
WATER SPRAY.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB IN INERT MATERIAL (SAND, VERMICULITE,
CLOTH, ETC.) AND PLACE IN A CONTAINER FOR LATER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE AT A
TEMPERATURE BELOW -40F. KEEP CONTAINERS SEALED.
Other Precautions:PRACTICE GOOD PERSONAL HYGIENE; AVOID SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE
OR EMERGENCY OCCURS; USE NIOSH/MSHA APPROVED RESPIRATOR WITH
ORAGNIC VAPOR CARTRIDGE OR SUPPLIED AIR RESPIRATOR OR SCBA,AS
REQUIRED.USE IAW 29 CFR 1910. 134 AND MANUFACTURER'S
RECOMMENDATIONS.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION (OR LOCAL EXHAUST IF
PRODUCT IS HEATED) TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:EYEBATH.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
KEY1=N1. MSDS REPRESENTS 1 PART OF A MULTIPLE PART KIT. ONLY THIS PART
MSDS WAS AVAILABLE FOR ENTRY AT TIME OF ENTRY (HCC MAY BE
AFFECTED). MSDS ENTERED BY DLA-HMIS UNDER PROJECT FOR GSA.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:260F,127C
Vapor Pres:NIL
Vapor Density:>1
Spec Gravity:1.8
Evaporation Rate & Reference:NIL
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT GREEN-TAN VISCOUS LIQUID; NO ODOR GIVEN.
Percent Volatiles by Volume:<1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:STORE AT TEMPERATURES BELOW -40F.
Hazardous Decomposition Products:NITROGEN OXIDES AND
NITROGEN-CONTAINING AND PHENOLIC COMPOUNDS MAY BE FORMED ON
COMBUSTION.
Conditions to Avoid Polymerization:AT TEMPERATURES ABOVE -40F WILL
REACT TO FORM A NON-HAZARDOUS SOLID.
==================== Disposal Considerations ====================
Waste Disposal Methods:AFTER CURING TO A SOLID, PRODUCT IS
NON-HAZARDOUS. DISPOSE OF IAW LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BLUE GLOSS AEROSOL ID GP-4891-5045
CAGE:59581
CAGE:59581
============= Composition/Information on Ingredients =============
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: .10%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: .88%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:METHYLENE CHLORIDE(SARA III)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 26.59%
OSHA PEL:500 PPM/C,1000; Z2
ACGIH TLV:50 PPM, A2; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 3.50%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:MINERAL SPIRITS (LEL .70)
CAS:64475-85-0
RTECS #:PY8240000
Fraction by Wt: 14.53%
ACGIH TLV:100 PPM
Ingred Name:VM&P NAPHTHA (LIGROINE)
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: .28%
OSHA PEL:300 PPM/400 STEL
ACGIH TLV:300 PPM; 9192
Ingred Name:ETHYL ALCOHOL (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 3.22%
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9192
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: .39%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HEXANE (N-HEXANE)
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: 4.56%
OSHA PEL:500 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:2-BUTOXYETHANOL
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: .97%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 18.0%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9192
Ingred Name:ISOBUTANE (LEL 1.90)
CAS:75-28-5
Fraction by Wt: 12.0%
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:HIGH VAPOR CONCENTRATIONS (>1000 PPM)
MAY HAVE NERVOUS SYSTEM EFFECTS INCLUDING DEATH.
Effects of Overexposure:INHALATION: MAY CAUSE RESPIRATORY SYSTEM
IRRITATION, HEADACHE, DIZZINESS, NAU- SEA, POSSIBLE
UNCONSCIOUSNESS, AND ASPHYXIATION.EYES: MAY CAUSE IRRITATION.
SKIN: MAY CAUSE DEFATTING OF THE SKIN, LEADING TO IRRITATION AND
DERMATITIS.INGESTION: CALL A PHYSICIAN IMMEDIATELY.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING STOPS, BEGIN
ARTIFICIAL RESPIRA-TION. SEEK IMMEDIATE MEDICAL ATTENTION.
SKIN: WASH WITH SOAP AND
WATER.INGESTIO N: CALL PHYSICIAN IMMEDIATELY.
EYES: IMMEDIATELY FLUSH WITH WATER FOR 15
MINUTES. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:10F/-12.22C
Extinguishing Media:USE CARBON DIOXIDE, DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. WATER MAY BE
USED TO COOL CONTAINERS TO PREVENTBURSTING. IF WATER IS USED, FOG
Unusual Fire/Explosion Hazard:EXPOSURE TO HEAT MAY CAUSE BURSTING OF
AEROSOL CAN.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION, AVOID
BREATHINGVAPORS, VENTILATE AREA, WIPE UP WITH INERT MATER- IALS
AND PLACE IN APPROPRIATE CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. EXPOSURE TO
HEAT ORPROLONGED EXPOSURE TO SUN MAY CAUSE BURSTING.
Other Precautions:USE ONLY AS DIRECTED. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING VAPORS AND INHALING CONTENTS CAN BE
HARMFUL OR FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID CONTINUOUS BREATHING OF VAPORS AND SPRAY
MIST. A SELF-CONTAINED BREATHINGAPPARATUS IS REQUIRED FOR
CONCENTRATIONS ABOVE TLV LIMITS.
Ventilation:USE WITH ADEQUATE VENTILATION, SUFFICIENT TO PREVENT
INHALATION OF SOLVENT VAPORS.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:NA
Vapor Density:>AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Percent Volatiles by Volume:85
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZING MATERIALS.
Stability Condition to Avoid:DO NOT STORE ABOVE 120F. KEEP FROM
SPARKS, PILOT LIGHTS OR OPEN FLAME.
Hazardous Decomposition Products:CARBON DIOXIDE AND/OR CARBON MONOXIDE.
HYDROGEN CHLORIDE VAPOR AND TRACES OF PHOSGENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE AEROSOL. DISPOSE OF IN ACCOR-
DANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS. DO NOT PLACE
AEROSOL CANS IN HOME COMPACTOR. DO NOT PUNCTURE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:STICK-EM FLY TRAPS
Preparer's Name:M.E.R. GODFREY, PH.D.
CAGE:27633
CAGE:0X818
CAGE:27633
============= Composition/Information on Ingredients =============
Ingred Name:MANUFACTURER CLAIMS ONLY NON-HAZARDOUS INGREDIENTS W/O
SPECIFYING ANY INDIVIDUAL INGREDIENT.
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:PRODUCT'S LD50 (ORAL RAT) WAS NOT STATED
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE KNOWN AT AMBIENT TEMPERATURES.
FOR HOT PRODUCT, INHALATION OF FAPORS MAY CAUSE IRRITATION OF
RESPIRATORY TRACT. SMALL INGESTED AMOUNTS ARE NOT EXPECTED TO
PRODUCE ADVERSE HEALTH EFFECTS. LARGER Q UANTITIES (>1 OZ) SHOULD
BE REMOVED FROMTHE STOMACH BY ASPIRATION. CALL A PHYSICIAN.
Explanation of Carcinogenicity:MFR GAVE THE ABOVE LISTINGS ON THE MSDS
BUT NO OTHER COMMENTS ABOUT CARCINOGENICITY WERE RECORDED.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:IF ANY IRRITATION PERSISTS OR SEVERE, GET MEDICAL ATTENTION.
EYE:FLUSH W/WATER FOR 15 MIN. SKIN:WASH W/SOAP & WATER.
INHALED:REMOVE TO FRESH AIR. INGESTED:SMALL QUANTITIES ARE NOT
EXPECTED TO PRODUCT ADVERSE HEALTH EFFECTS. LARGER QUANTITIES (>1
OZ) SHOULD BE RECOVERED BY STOMACH ASPIRATION. CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>338F,>170C
Autoignition Temp:Autoignition Temp Text:N/A.
Lower Limits:N/A.
Upper Limits:N/A.
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR BUTYL RUBBER BOOTS,
Unusual Fire/Explosion Hazard:NO KNOWN UNUSUAL HAZARDS IN A
FIRE-EXPLOSION SITUATION.
================== Accidental Release Measures ==================
Spill Release Procedures:MATERIAL IS SOLID ADHESIVE. IT WILL NOT FLOW
OUT. IF RECOVERY IS NOT FEASIBLE, ADD MIX W/DRY INERT ABSORBENT &
PLACE IN CONTAINER OR DUMPSTER PENDING DISPOSAL. SOVEL SPILLED
MATERIAL INTO EMPTY, DRY C ONTAINER FOR LATER DISPOSAL OR RECOVERY.
Neutralizing Agent:MFR GAVE NO INFORMATION OF MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN COOL, DRY, WELL VENTILATED
STORAGE AREAS. HANDLE IN WELL VENTILATED AREAS.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER NOTMAL CONDITIONS. FOR
EMERGENCY SITUATIONS USE SELF-CONTAINED BREATHING APPARATUS IN
POSITIVE PRESSURE MODE.
Ventilation:NO ARTIFICIAL VENTILATION NEEDED
Other Protective Equipment:MFR GAVE NO INFORMATION OF MSDS.
Work Hygienic Practices:PROVIDE REDILY ACCESSIBLE EYE WASH STATIONS.
PROMPTYLY WASH SKIN IF CONTAMINATED. REMOVE FROM SKIN W/VEGETABLE
OIL.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NONE
Boiling Pt:B.P. Text:N/A.
Melt/Freeze Pt:M.P/F.P Text:N/A.
Vapor Pres:NEGLIGIBLE
Vapor Density:N/A.
Spec Gravity:0.93
Evaporation Rate & Reference:NEGLIGIBLE
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR TO PALE YELLOW TACKY SOLID, PETROLEUM ODOR
Percent Volatiles by Volume:N/A.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:MFR GAVE NO INFORMATION OF MSDS.
Hazardous Decomposition Products:CARBON DIOXIDE &/OR CARBON MONOXIDE IN
FIRE. POTENTIALLY IRRITATING & TOXIC FUMES AT ELEVATED
TEMPERATURES.
Conditions to Avoid Polymerization:MFR GAVE NO INFORMATION OF MSDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASH DOWN AFFECTED AREA TO REMOVE MATERIAL FROM
SURFACE OF FLOOR. LANDFILL I/A/W FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: TONER CASSETTE TYPE 30, SM3000
Cage: RICOH
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 2Z665
Cage: RICOH
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:EYES:MAY CAUSE TEMPORARY DISCOMFORT. INHAL:GASPING.
INGEST: >5 G/KG BODY WT, PRACTICALLY NON-TOX. CHRONIC:A XEROX SPONSORED
CHRONIC INHAL STUDY IN RATS USING A SPECIAL TEST TONER REVEALED THERE WERE
NO LUNG CHANGES AT ALL IN LOWEST EXPOS LEVEL (1 MG/M3), MOST RELEVANT LEVEL
TO POTNTL HUMAN (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:EXPOS. A VERY SLIGHT DEGREE OF
FIBROSIS WAS NOTED IN 25% OF ANIMALS AT MIDDLE EXPOS LEVEL (4 MG/M3) WHILE A
SLIGHT DEGREE OF FIBROSIS WAS OBSERVED AT HIGHEST EXPOS LEVEL (16 MG/M3) IN
ALL ANI MALS. THESE FINDINGS ARE ATTRIBUTED TO "LUNG OVERLOADING", A GENERIC
RESPONSE TO EXCESSIVE AMTS OF ANY DUST (SUPP DATA)
Medical Cond Aggravated By Exposure: NONE.
First Aid: EYES:TRY TO REMOVE OR FLUSH OUT W/EYE DROPS FOR AT LEAST 15 MINUTES.
IF IRRITATION PERSISTS, GET MEDICAL ATTENTION. SKIN:WASH THOROUGHLY W/SOAP
& WATER. INHAL:REMOVE FROM EXPOSURE. INGEST:DILUTE STOMA CH CONTENTS
W/SEVERAL GLASSES OF WATER.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: IF SPILLED, SWEEP UP USING APPRVD TONER VACUUM
CLEANER W/0.5 MICRON FILTER/SMALLER SUCH AS ATRIX AAA VACUUM (RICOH EDP CODE
342MIU). USE OF VACUUM CLEANER NOT RATED FOR TONER PARTICULATE COULD BE POTN
TL FIRE HAZ &/OR RSLT IN PERSONAL INJURY. (SUPDAT)
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISP MUST BE I/A/W FED, STATE & LOC REGS (FP N).
USED TONER SHOULD BE DISPOSED OF IN AN ENVIRONMENTALLY SAFE MANNER &
I/A/W GOVT REGS. DISP REGS VARY FROM LOCALITY TO LOCALITY, THEREFORE, CONSULT
W/YO UR LOC OFFICE OF THE EPA TO DETERMINE (SUPP DATA)
Handling And Storage Precautions: STORE IN A COOL, DRY PLACE. KEEP OUT OF REACH
OF CHILDREN. DO NOT HANDLE IN AREAS WHERE WIND BLOWS. FLYING POWDER MAY ENTER
EYES.
Other Precautions: MINIMIZE INHALATION OF DUST.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: CO*2, DRY CHEMICALS, FOAM OR WATER.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). NO SPECIAL FIRE-FIGHTING PROCEDURE IS NECESSARY.
Unusual Fire/Explosion Hazard: AIRBORNE DISPERSAL OF MOST FINELY DIVIDED
ORGANIC POWDERS SUCH AS TONER MAY FORM EXPLOSIVE MIXTURE. DO NOT INCINERATE
LOOSE OR SPILLED TONER.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF
CONCERN (FP N). NONE NEEDED UNDER NORMAL CONDITIONS OF USE.
Ventilation: LOCAL EXHAUST:NONE NEEDED UNDER NORMAL CONDITIONS OF USE.
MECHANICAL (GENERAL):ADEQUATE VENTILATION.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: CLEANSE SKIN THOROUGHLY AFTER CONTACT, BEFORE BREAKS &
MEALS, & AT END OF WORK PERIODS.
Supplemental Safety and Health: NOTE:USERS OF "L" VERSION SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). SPILL PROC:REMOVE RESIDUE W/SOAP & WATER.
WASTE DISP METH:PROPER METH OF DISP. DO NOT INCIN LOOSE/SPILLED TONER. EFTS
OF OV EREXP:RETAINED IN LUNGS FOR PRLNG INTERVAL. THE SPECIAL TEST TONER WAS
TEN TIMES MORE RESPIRABLE THAN
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 1.9
Appearance and Odor: BLACK POWDER W/SLIGHT PLASTIC ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE.
Materials To Avoid: NONE.
Hazardous Decomposition Products: CARBON MONOXIDE & OTHER DECOMPOSITION
PRODUCTS IN THE CASE OF COMBUSTION.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: TONER CASSETTE TYPE 30, SM3000
Cage: RICOH
Assigned IND: Y
Company Name: RICOH CORP
Street: 5 DEDRICK PLACE
Zipcode: 07006
Label Required IND: Y
Date Of Label Review: 07/23/1997
Status Code: C
Label Date: 07/23/1997
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE:EYES:DISCOMFORT. INHALATION:GASPING.
INGESTION:PRACTICALLY NON-TOXIC. CHRONIC:LUNG FIBROSIS POSSIBLE.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HT15-2 MASSON TRICHROME KIT PHOSPHOTUNGSTIC ACID (SEE SUPPL)
Kit Part:Y
Resp. Party Other MSDS Num.:CUSTOMER # 8-091-99999
CAGE:TO565
CAGE:TO565
============= Composition/Information on Ingredients =============
Ingred Name:COMPOSITION/INFORMATION ON INGREDIENTS: NONE.
===================== Hazards Identification =====================
LD50 LC50 Mixture:NO DATA PROVIDED BY MANUFACTURER
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:ACUTE EFFECTS: MATERIAL IS EXTREMELY
DESTRUCTIVE TO TISSUE OF THE MUCOUS MEMBRANES AND UPPER RESPIRATORY
TRACT, EYES AND SKIN. INHALATION MAY RESULT IN SPASM, INFLAMMATION
AND EDEMA OF THE LARYNX AND BRONCHI, CHEMICAL PNEUMONITIS AND
PULMONARY EDEMA. SYMPTOMS OF EXPOSURE MAY INCLUDE BURNING
SENSATION, COUGHING, WHEEZING, LARYNGITIS, SHORTNESS OF BREATH,
HEADACHE, NAUSEA AND VOMITING. MAY BE HARMFU L IF ABSORBED THROUGH
THE SKIN. MAY BE HARMFUL IF INHALED. HARMFUL IF SWALLOWED.
Explanation of Carcinogenicity:NO DATA PROVIDED BY MANUFACTURER.
Effects of Overexposure:ACUTE EFFECTS: MATERIAL IS EXTREMELY
DESTRUCTIVE TO TISSUE OF THE MUCOUS MEMBRANES AND UPPER RESPIRATORY
TRACT, EYES AND SKIN. INHALATION MAY RESULT IN SPASM, INFLAMMATION
AND EDEMA OF THE LARYNX AND BRONCHI, CHEMICAL PNEUMONITIS AND
PULMONARY EDEMA. SYMPTOMS OF EXPOSURE MAY INCLUDE BURNING SENSATIN,
COUGHING, WHEEZING, LARYNGITIS, SHORTNESS OF BREATH, HEADACHE,
NAUSEA AND VOMITING. MAY BE HARMFUL IF ABSORBED THROUGH THE SKIN.
MAY BE HARMFUL IF INHALED. HARMFUL IF SWALLOWED.
Medical Cond Aggravated by Exposure:NO DATA PROVIDED BY MANUFACTURER
======================= First Aid Measures =======================
First Aid:ORAL EXPOSURE: IF SWALLOWED, WASH OUT MOUTH WITH WATER
PROVIDED PERSON IS CONSCIOUS. CALL A PHYSICIAN. INHALATION
EXPOSURE: IF INHALED, REMOVE TO FRESH AIR. IF NOT BREATHING GIVE
ARTIFICIAL RESPIRATIO N. IF BREATHING IS DIFFICULT, GIVE OXYGEN.
DERMAL EXPOSURE: IN CASE OF CONTACT, IMMEDIATELY WASH SKIN WITH
SOAP AND COPIOUS AMOUNTS OF WATER. EYE EXPOSURE: IN CASE OF
CONTACT, IMMEDIATELY FLUSH EYES W ITH COPIOUS AMOUNTS OF WATER FOR
AT LEAST 15 MINUTES. ASSURE ADEQUATE FLUSHING BY SEPARATING THE
EYELIDS WITH FINGERS. CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL POWDER,
OR APPROPRIATE FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE-CLOTHING TO PREVENT CONTACT WITH SKIN AND EYES. USE
WATER SPRAY TO COOL FIRE-EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
CONTAT WITH OTHER MATERIAL MAY CAUSE FIRE.
================== Accidental Release Measures ==================
COVER WITH DRY LIME OR SODA ASH, PICK UP, KEEP IN A CLOSED
CONTAINER, AND HOLD FOR WASTE DISPO SAL. VENTILATE AREA AND WASH
SPILL SITE AFTER MATERIAL PICKUP IS COMPLETE. EVACUATE AREA.
Neutralizing Agent:DRY LIME OR SODA ASH.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP TIGHTLY CLOSED. STORE IN A COOL
DRY PLACE. HANDLING USER EXPOSURE: DO NOT BREATHE VAPOR. AVOID
CONTACT WITH EYES, SKIN, AND CLOTHING. DO NOT BREATHE VAPOR. AVOID
PROLONGED OR REPEATED EXPOSURE.
Other Precautions:NO DATA PROVIDED BY MANUFACTURER
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA-APPROVED RESPIRATOR. DO NOT BREATHE
VAPOR. DO NOT GET IN EYES, ON SKIN, ON CLOTHING. AVOID PROLONGED OR
REPEATED EXPOSURE.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:SAFETY SHOWER AND EYEBATH. USE ONLY IN A
CHEMICAL FUME HOOD. DO NOT BREATHE VAPOR. DO NOT GET IN EYES, ON
SKIN, ON CLOTHING. AVOID PROLONGED OR REPEATED EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. WASH
CONTAMINATED CLOTHING BEFORE REUSE. DISCARD CONTAMINATED SHOES.
Supplemental Safety and Health
4-PART KIT: PART (1) BIEBRICH SCARLET-ACID FUCHSIN (# CLMBP),PART
(2) PHOSPHOTUNGSTIC ACID SOLUTION, 10% W/V, PART (3)
PHOSPHOMOLYBDIC ACID SOLUTION, 10% W/V (# CLMBX), PART (4) ANILINE
BLUE SOLUT ION (#CLMBY).
================== Physical/Chemical Properties ==================
HCC:C1
Appearance and Odor:LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:STABLE.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY PRODUCE
TOXIC FUMES OF PHOSPHORUS OXIDES AND/OR PHOSPHINE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:ACUTE EFFECTS: MATERIAL IS EXTREMELY
DESTRUCTIVE TO TISSUE OF THE MUCOUS MEMBRANES AND UPPER RESPIRATORY
TRACT, EYES AND SKIN. INHALATION MAY RESULT IN SPASM, INFLAMMATION
AND EDEMA OF THE LARYNX AND BRONCHI, CHEMICAL PNEUMONITIS AND
PULMONARY EDEMA. SYMPTOMS OF EXPOSURE MAY INCLUDE BURNING
SENSATION, COUGHING, WHEEZING, LARYNGITIS, SHORTNESS OF BREATH,
HEADACHE, NAUSEA AND VOMITING. MAY BE HARMFU L IF ABSORBED THROUGH
THE SKIN. MAY BE HARMFUL IF INHALED. HARMFUL IF SWALLOWED.
===================== Ecological Information =====================
Ecological:DATA NOT YET AVAILABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE OR MIX THE MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN AFTER
BURNER AND SCRUBBER OBSERVE ALL FEDERAL, STATE, AND LOCAL
ENVIRONMENTAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:CONTACT SIGMA CHEMICAL COMPANY FOR TRANSPORTATION
INFORMATION.
===================== Regulatory Information =====================
SARA Title III Information:NO DATA PROVIDED BY MANUFACTURER
Federal Regulatory Information:NO DATA PROVIDED BY MANUFACTURER
State Regulatory Information:NO DATA PROVIDED BY MANUFACTURER
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CERTANE 909
CAGE:0SYZ1
CAGE:0SYZ1
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL) >5 G/KG
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE TO MINIMAL IRRITATION OF THE
EYES. SLIGHTLY IRRITATING TO THE SKIN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMEDIATELY . INHAL: REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE OXYGEN/ARTIFICIAL RESPIRATION) . SKIN: WASH
EXPOSED AREAS WITH SOAP AND WATER IMMEDIATELY. EYES: FLUSH EYE S
WITH WATER FOR AT LEAST 15 MINUTES. AVOID BREATHING MISTS.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT MATERIAL OR SCOOP TO PICK UP
BULK SPILL. FLUSH FINAL TRACES WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING. KEEP CONTAINER
SEALED WHEN NOT IN USE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR NOT NORMALLY REQUIRED. USE NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:PRECAUTIONS AS PER NORMAL LATEX PAINT SPRAYING ACTIVITIES.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER . USE
APPROVED CLOTHING WHEN USING PRODUCT FOR POST ASBESTOS CLEAN-UP.
Work Hygienic Practices:FOLLOW ALL APPLIC OSHA/EPA ETC REGS CONCERNING
ASBESTOS HEALTH HAZS WHEN USING THIS PROD AS POST-ASBESTOS (SUPDAT)
Supplemental Safety and Health
HYGIENE PRACT: SPRAY-BACK ENCAPSULANT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Spec Gravity:1.09 (H*2O=1)
Solubility in Water:DISPERSIBLE
Appearance and Odor:WHITE LATEX - DRIES TO CLEAR FILM. LATEX PAINT
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:KEEP FROM FREEZING.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE IN SUITABLE CONTAINER FOR DISPOSAL
ACCORDING TO LOCAL, STATE AND FEDERAL REGULATIONS FOR WATER-BASED
COATINGS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:IMPROVED GERMICIDAL CLEANING SOLUTION
Preparer's Name:J.J. GENOVESE
CAGE:59825
PRODUCTS
CAGE:59825
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 10%
Other REC Limits:400 PPM
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
Ingred Name:DODECYL DIMETHYL ETHYLBENZYL AMMONIUM CHLORIDE *93-4*
CAS:27479-28-3
Ingred Name:DIMETHYL-BENZYLAMMONIUM CHLORIDE
CAS:139-08-2
RTECS #:BO7150000
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:EYES: IRRIGATE W/COPIUS AMOUNTS OF WATER. SKIN: WASH AREA
W/WATER. INGESTION: CONSULT PHYSICIAN. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:103F
Extinguishing Media:WATER, FOAM
Unusual Fire/Explosion Hazard:TREAT LIQUID AS COMBUSTIBLE
================== Accidental Release Measures ==================
Spill Release Procedures:LARGE: CONTAIN TO PREVENT DISCHARGE INTO
ENVIRONMENT NON-HAZARDOUS WASTE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL DRY PLACE AWAY FROM
SOURCES OF IGNITION & HEAT.
============= Exposure Controls/Personal Protection =============
Ventilation:PROVIDE FOR ADEQUATE AIR MOVEMENT
Work Hygienic Practices:WASH HANDS AFTER USE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:181.5F
Spec Gravity:0.983
Solubility in Water:INFINITE
Appearance and Odor:CLEAR COLORLESS LIQUID W/ALCOHOLIC ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ANIONIC SURFACTANTS, SOAPS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SEALED LEAD BATTERY CLOSED CYLINDRICAL
CAGE:0WY95
CAGE:0WY95
============= Composition/Information on Ingredients =============
Ingred Name:LEAD (SARA III) - TOTAL OF INGREDIENTS 1 & 2 IS 69%.
CAS:7439-92-1
RTECS #:OF7525000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.05 MG/M3;1910.1025
ACGIH TLV:0.15 MG/M3;DUST 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:LEAD OXIDE
CAS:1317-36-8
RTECS #:OG1750000
Fraction by Wt: SEE # 1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SULFURIC ACID (SARA III)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 21%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:NON HAZARDOUS INGREDIENTS
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:PRODUCT'S LD50 (ORAL RAT) WAS NOT STATED
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:NOT APPLICABLE FOR FINISHED PRODUCT
USED IN NORMAL CONDITIONS.
Explanation of Carcinogenicity:MFR DID NOT LIST CARCINOGENICITY AS USER
IS UNLIKELY TO CONTACT THE LEAD (POSSIBLY CARCINOGENIC TO HUMANS).
Effects of Overexposure:MFR GAVE NO INFORMATION ON MSDS.
Medical Cond Aggravated by Exposure:MFR GAVE NO INFORMATION ON MSDS.
======================= First Aid Measures =======================
First Aid:BATTERY CONTAINS ACID ELECTROLYTE. IF BATTERY CASE IS
PUNCTURED COMPLETELY FLUSH ANY RELEASED MATERIAL FROM SKIN OR EYES
WITH WATER.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:MULTI-PURPOSE DRY CHEMICAL OR MULTI-PURPOSE CO2.
Fire Fighting Procedures:COOL BATTERY EXTERIOR TO PREVENT RUPTURE. ACID
MISTS & VAPORS IN FIRE ARE TOXIC & CORROSIVE THERFORE WEAR
PROTECTIVE EQPMT.
Unusual Fire/Explosion Hazard:HYDROGEN GASMAY BE PRODUCED & MAY EXPLODE
IF IGNITED. REMOVE ALL SOURCES OF IGNITION. VENTILATE AREA.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID CONTACT WITH SULFURIC ACID MATERIALS.
USE LIME OR SODA TO NEUTRALIZE. FLUSH W/LARGE AMOUNTS OF WATER.
Neutralizing Agent:SODA ASH OR LIME
======================Handling and Storage ======================
Handling and Storage Precautions:MFR GAVE NO INFORMATION ON MSDS.
Other Precautions:READ MANUFACTURERS LITERATURE WHICH IS AVAILABLE UPON
REQUEST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT APPLICABLE FOR FINISHED PRODUCT.
Ventilation:NOT APPLICABLE FOR FINISHED PRODUCT.
Other Protective Equipment:MFR LISTED 'NOT APPLICABLE FOR FINISHED
PRODUCT.' FOR RESPIRATORY PROTECTION & LEFT REST OF PERSONAL
PROTECTION BLANK.
Work Hygienic Practices:MFR ? HMIS:NO PRECAUTIONS NECESSARY UNLESS
BATTERY CASE IS BROKEN, THEN USE STRICT CHEMICAL HYGIENE
PROCEDURES.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MFR GAVE NO INFORMATION ON MSDS.
Stability Condition to Avoid:AVOID SHORTING. USE ONLY APPROVED CHARGING
METHODS.
Hazardous Decomposition Products:MFR GAVE NO INFORMATION ON MSDS.
Conditions to Avoid Polymerization:WILL NOT OCCUR. DO NOT PUNCTURE
BATTERY CASE.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE IN ACID RESISTANT CONTAINERS. DISPOSE OF
I/A/W LOCAL, STATE AND FEDERAL REGULATIONS. DO NOT INCINERATE.
======================================================================
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:2622 ENAMEL, LUSTERLESS, AEROSOL,GRAY
CAGE:91794
CAGE:91794
============= Composition/Information on Ingredients =============
Ingred Name:METHYLENE CHLORIDE(DICHLOROMETHANE) (SARA III)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 21.9%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM; Z-2
ACGIH TLV:50 PPM, A2; 9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ISOBUTAE/PROPANE MIXTURE (PROPELLANT)
===================== Hazards Identification =====================
Effects of Overexposure:INHAL:ANEST.IRRIT OF RESPIR TRACT OR ACUTE NERV
SUS.HDACH,DIZZ,STAGGERING GAIT,CONFUSION,UNCONS,COMA
======================= First Aid Measures =======================
First Aid:FUMES:REMOV FR EXPOS.GET FRESH AIR.SPRAY EYES:FLUSH IMMED
W/LG QTY RUNNING WATER.F/AT LEAST 15 MIN TAKE TO DR.SPRAY SKN,WIPE
OFF W/TOWEL.REMOV REMAIN W/MINER SPIRITS,TURPENT, LACQ THINNER IN
CASE OF A LACQ. WASH W/SOAP & WATER.REMOV CONTAMCLOTHING.
===================== Fire Fighting Measures =====================
Flash Point:-40 F -40 C
Lower Limits:0.8%
Extinguishing Media:NFPA CLASS B EXTING (CO*2, DRY CHEM OR FOAM)F/CLAS
IA FLAMMA
Fire Fighting Procedures:WEAR GOGG & SELF-CONTAINED.BREATHING
APPARATUS.
Unusual Fire/Explosion Hazard:CNS. W/RUPTURE FROM INTERN PRESSR AT
ABOUT 190 F & DISCHRG FLAMMB CONTNTS.TOXIC FUMES IF HEATTO DECO
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT (FLAMES,HOT
SURFACES & ELECTRICAL, STATIC OR FRICTIONAL SPARKS).AVOID BREATHING
VAP.VENTILAT AREA. REMOV WITH INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120 F. STORE LG
QUANTITIES IN BLDGS DESIGNED & PROTECTED FOR STORAGE OF NFPA CLASS
IA FLAMMALBE LIQUIDS.
Other Precautions:DO NOT SPRAY IN EYES.DO NOT PUNCTURE OR INCINER
CNS.DO NOT STICK PIN,NAIL OROTHER SHARP OBJECTS INTO OPENING ON TOP
OF CAN.DO NOT TAKE INTERNALLY.DO NOT FLAMECUT,BRAZE OR WELD W/O BUR
OF (SUPP
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR CASUAL USE NONE REQD,PROV VENTILAT IS AVAIL
AS OUTLINED BELOW.
Ventilation:DILUTION OR EXHAUST TO KEEP BELOW TLV.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:42 F-391%
Evaporation Rate & Reference:PROPELLANT-FASTER
Percent Volatiles by Volume:75%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:HYDROGEN CHLORIDE, CARBONMONOXIDE,
PHOSGENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL STATE & FEDERAL
REGULATIONSINCINERATE IN APPRVD FACILITY. DO NOT INCINERATE CLOSED
CONTAINERS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:CHLORINE
CAGE:91784
CAGE:91784
============= Composition/Information on Ingredients =============
Ingred Name:CHLORINE (SARA 302/313) (CERCLA)
CAS:7782-50-5
RTECS #:FO2100000
Fraction by Wt: 99.5%
OSHA PEL:C 1 PPM
ACGIH TLV:0.5 PPM/1 STEL
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:DISSOLVED GASES
Fraction by Wt: 0.5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:HAZ DECOMP PROD: CHLORINE IS STABLE IN STEEL CONTAINERS AT
ROOM TEMPERATURE WHEN DRY. INTENSE LOCAL HEAT ON (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3: STEEL WALLS CAN CAUSE THE STEEL TO REACT AND GLOW IN
PRESENCE OF CHLORINE.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP: REPORTED AT VARIOUS CONCS & APPEARS TO BE
BETWEEN 0.02 & 0.2 PPM FOR MOST SUBJECTS. THERE IS (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: EVIDENCE THAT OLEFACTORY FATG DEVELOPS & SOME
TOLERANCE IS BUILT UP IN CHRONIC LOW LEVEL EXPOS. TOXICITY: (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: STRONG IRRIT TO SKIN, EYES & MUC MEMB. HAZ AT
DIFFERENT ATM CONCS IS REPORTED TO BE AS FOLLOWS: 0.02-0.2: (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:ODOR THRESHOLD; 0.2-0.5: NO TOX, LONG TERM EFT; 1-3:
DEFINITE ODOR, IRRIT OF EYES & NOSE; 6: THROAT (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: IRRIT; 30: INTENSE COUGHING FITS; 40-60: EXPOS FOR
30-60 MIN MAY CAUSE SERIOUS INJURY; 100: MAY BE (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: FATAL; 1000: MAY BE FATAL WITH A FEW DEEP BREATHS.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: WATER. IF IRRIT IS PRESENT AFTER WASHING,
GET MED ATTN. INHAL: REMOVE TO FRESH AIR. RESTORE (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: BRTHG WHEN REQUIRED. HAVE TRAINED PERS ADMIN OXYGEN
UNTIL VICTIM BREATHES EASILY ON HIS OWN. KEEP WARM (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: & AT REST. IN MILD CASES, GIVE MILK TO RELIEVE
THROAT IRRIT. DO NOT TRY TO INDUCE VOMIT. GET MED ATTN (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: AS SOON AS POSS! INGEST: CALL MD IMMED .
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: ASSIGNED PERS W/APPRVD EQUIP & CLTHG.
UNCONTROLLABLE LEAKS MAY REQUIRE ACTIVATION OF FACILITY EMER (ING
16)
RTECS #:9999999ZZ
Ingred Name:ING 15: RESPONSE PLAN W/POSS EVACUATION OF SURROUNDING
AREA. KEEP MATL OUT OF WATER COURSES & SEWERS. DO NOT (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: APPLY WATER TO POINT OF LEAK.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: LIQUID LEVELS SHOULD BE LESS THAN 85% OF TANK
OR CYLINDER CAPACITY.
RTECS #:9999999ZZ
Ingred Name:VENT: AREAS. USE ENCLOSED, ISOLATED PROCESSING AND HANDLING
WHENEVER POSSIBLE.
RTECS #:9999999ZZ
Ingred Name:OTHER PROT EQUIP: LIQUID OR GAS. EYEWASH STATIONS AND
SAFETY SHOWERS MUST BE AVAILABLE IN WORK AREAS.
RTECS #:9999999ZZ
Ingred Name:SUP DAT: RESPECTIVELY, WHICH ARE TOXIC AND CORROSIVE
SUBSTANCES.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEV EXPOS TO CHLORINE VAP CAN BE
FATAL. EXPOS TO LIQ CHLORINE CAN CAUSE EYE & SKIN BURNS ON CONT.
PROMPT TREATMENT IMPORTANT TO MIN EFTS OF OVEREXP. CONT W/LIQ
CHLORINE MAY CAUSE BURNS, BLISTERING & T ISS DESTRUCTION. EXPOS TO
CHLORINE GAS MAY CAUSE SEV IRRIT OF MUC MEMB OF EYES, NOSE, THROAT
& RESP (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: TRACT FOLLOWED BY SEV COUGHING,
BURNING, CHEST PAIN, VOMIT, HDCH, ANXIETY, & FEELING OF
SUFFOCATION, WHICH MAY BE DELAYED IN ONSET. SEV EXPOS MAY LEAD TO
PNEUMIT & PULM EDEMA & MAY BE FATAL. RPTD/PRLNG EXPOS MAY RSLT IN
REDUCED PULM CAPACITY & DENTAL EROSION. ODOR THRESHOLD FOR CHLORINE
HAS BEEN (ING 5)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IMMED FLUSH W/DIRECTED STREAM OF WATER FOR AT LEAST 15
MIN WHILE HOLDING EYELIDS APART TO ENSURE COMPLETE IRRIGATION OF
ALL EYE & LID TISS. GET MED ATTN! CONT LENSES SHOULD NOT BE WORN
WHEN WORK ING W/CHLORINE. SKIN: TREAT FOR INHAL EXPOS FIRST. REMOVE
CONTAM CLTHG UNDER SFTY SHOWER. FLUSH EXPOS SKIN AREAS W/PLENTY OF
WATER FOR AT LEAST 15 MIN. CLEAN AFFECTED AREAS W/SOAP & WARM (ING
11)
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . USE WATER SPRAY TO COOL INTACT, FIRE-EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CHLORINE WILL SUPPORT THE BURNING OF MOST
COMBUSTIBLES JUST AS OXYGEN DOES. FLAMMABLE GASES AND VAPORS CAN
FORM EXPLOSIVE MIXTURES WITH CHLORINE.
================== Accidental Release Measures ==================
Spill Release Procedures:HAVE ESTABLISHED WRITTEN EMER PLANS & SPECIAL
TRAINING OF PERS IN AREAS WHERE CHLORINE IS USED. KEEP UPWIND,
NOTIFY SFTY PERS, PROVIDE VENT, WEAR FULL PROT EQUIP & SHUT OFF
SUPP AT SOURCE. EXCLUDE FRO M AREA ALL EXCEPT SPECIALLY TRAINED,
(ING 15)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE CONTRS IN WELL-VENT AREAS OF LOW
FIRE POTENTIAL, AWAY FROM INCOMPATIBLE MATLS & AWAY FROM SOURCES OF
HEAT & IGNIT.
Other Precautions:PROT CONTRS FROM WEATHER & PHYSICAL DMG & FOLLOW STD
SFTY PROC FOR CONTRS OF COMPRESSED, CORR GASES. PROVIDE SPECIAL
TRAINING TO WORKERS HNDLG CHLORINE. REGULARLY TEST & INSPECT PIPING
& CONTAINMENT U SED FOR CHLORINE SERVICE. (ING 18)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED FULL-FACE RESPIRATORS MUST
BE AVAILABLE FOR NON-ROUTINE AND EMERGENCY USE. CANISTER (ACID-GAS)
TYPE SUITABLE FOR LOW CONCENTRATIONS ONLY.
Ventilation:PROVIDE GENERAL AND LOCAL EXHAUST VENTILATION TO MEET TLV
OF 1 PPM. PROVIDE SUITABLE VENTING FOR LOW LYING (ING 19)
Other Protective Equipment:FULL PROTECTIVE CLOTHING AND SAFETY
EQUIPMENT MUST BE IMMEDIATELY AVAILABLE TO PREVENT EXPOSURE TO
CHLORINE, (ING 20)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MATLS TO AVOID: CNDTNS INCL REDUCING AGENTS AND COMBUST MATLS. IT
SHOULD BE KEPT AWAY FROM ACETYLENE, TURPENTINE, OTHER HYDROCARBONS,
AMMONIA, HYDROGEN, ETHER, POWDERED METALS, SULFUR AND ALUMINUM. CH
LORINE REACTS WITH H*2S AND H*2O FORMING HCL. COMBINES WITH CO AND
SO*2 TO FORM PHOSGENE AND SULFURYL CHLORIDE, (ING 21)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:-29F,-34C
Vapor Pres:4800 @ 20C
Vapor Density:2.49 @ 0C
Spec Gravity:1.41 @ 20C
Solubility in Water:1.46% @ 0C
Appearance and Odor:GREENISH-YELLOW GAS/CLEAR, AMBER COLORED LIQ
W/SUFFOCATING, PUNGENT, IRRIT ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CHLORINE IS A POWERFUL OXIDIZING AGENT WHICH REACTS VIOLENTLY W/VARIETY
OF SUBSTANCES OVER A BROAD RANGE OF (SUP DAT)
Stability Condition to Avoid:THE PRESENCE OF MOISTURE IN GASEOUS AND
LIQUID CHLORINE INCREASES CORROSIVE ATTACK ON MOST COMMON METALS.
Hazardous Decomposition Products:CHLORINE DOES NOT DECOMPOSE BUT REACTS
VIOLENTLY TO FORM HCL & OTHER POTENTIALLY TOX &/CORR SUBSTANCES.
(ING 3)
==================== Disposal Considerations ====================
Waste Disposal Methods:WHEN POSS, MOVE LEAKING CONTR TO ISOLATED AREA.
POSITION TO RELEASE GAS, NOT LIQ. ABSORB IN ALKALINE SOLN OF
CAUSTIC SODA, SODA ASH/HYDRATED LIME. SUITABLY DISP OF RESULTING
WASTE & COMPLY W/APPLIC LO CAL, STATE, AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:16741 LOCK BOND CLEAR THIN SPREAD FLOOR TILE ADHESIVE
CAGE:82464
CAGE:82464
============= Composition/Information on Ingredients =============
Ingred Name:METHANOL (METHYL ALCOHOL), COLUMBIAN SPIRITS
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: <3.5%
Other REC Limits:200 PPM
OSHA PEL:260 MG/CUM
ACGIH TLV:262 MG/CUM (SKIN)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VOL ORGANIC CMPD: 85 G/LITER
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: VAPORS MAY CAUSE MILD
IRRITATION OF RESPIRATORY TRACT. SKIN: PROLONGED CONTACT MAY CAUSE
IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SKIN: WASH AREA W/SOAP &
WATER. INGESTION: DON'T INDUCE VOMITING. EYES: FLUSH W/WATER FOR 15
MINS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:SEE SUPP
Lower Limits:1
Upper Limits:7
Extinguishing Media:CO2, FOAM, DRY CHEMICAL
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS IN POSITIVE
PRESSURE MODE & FULL PROTECTIVE GEAR SHOULD BE WORN.
Unusual Fire/Explosion Hazard:IRRITATING/TOXIC GASES & AEROSOLS MAY BE
PRODUCED DURING BURNING. BOILS W/O FLASHING.
================== Accidental Release Measures ==================
Spill Release Procedures:SCRAPE INTO CONTAINERS & DISPOSE OF. PROVIDE
ADEQUATE VENTILATION.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE NEAR HEAT SOURCES,
SPARKS/FLAME. STORE BETWEEN 40-120F. DON'T FREEZE. KEEP CONTAINER
CLOSED WHEN NOT IN USE.
Other Precautions:DON'T INGEST. KEEP AWAY FROM CHILDREN.
============= Exposure Controls/Personal Protection =============
Ventilation:LOCAL EXHAUST: RECOMMENDED. DON'T USE IN CLOSED SPACES.
Work Hygienic Practices:WASH SKIN & HANDS AFTER USE.
Supplemental Safety and Health
PRODUCT BOILS W/O FLASHING >200F.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:190-200F
Vapor Pres:96
Vapor Density:>1
Spec Gravity:0.98
Solubility in Water:COMPLETE
Appearance and Odor:CREAM COLORED PASTE W/SLIGHT AMMONIA ODOR
Percent Volatiles by Volume:50-52
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT SOURCES, SPARKS, FLAME, FREEZING
Hazardous Decomposition Products:CO, CO2, WATER, OXIDES OF NITROGEN
Conditions to Avoid Polymerization:EXCESSIVE HEAT/COLD
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:187A120, 5-STAR INTERIOR LATEX SEMI-GLOSS O
CAGE:ACEHA
CAGE:ACEHA
============= Composition/Information on Ingredients =============
Ingred Name:1-PROPANOL, 2-AMINO-2-METHYL-;
(2-AMINO-2-METHYL-1-PROPANOL). VP: 0.8.
CAS:124-68-5
RTECS #:UA5950000
Fraction by Wt: <0.5%
OSHA PEL:20 PPM (MFR)
ACGIH TLV:10 PPM (MFR)
Ingred Name:ETHYLENE GLYCOL (SARA III). VP: 0.1.
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 3%
OSHA PEL:50 PPM, C
ACGIH TLV:50 PPM, C, VAPOR
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:AMMONIA (SARA III). VP: 290.
CAS:7664-41-7
RTECS #:BO0875000
Fraction by Wt: <0.1%
OSHA PEL:50 PPM
ACGIH TLV:25 PPM/35 STEL; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IN CONFINED AREA, VAPORS IN
HIGH CONCENTRATION ARE ANESTHETIC. IRRITANT TO SKIN AND UPPER
RESPIRATORY SYSTEM. OVEREXPOSURE MAY RESULT IN LIGHTHEADEDNESS AND
STAGGERING GAIT.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:CHRONIC PROBLEMS W/RESPIRATORY
SYSTEM MAY BE AGGRAVATED BY EXPOSURE TO VAPORS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM &
QUIET. SKIN: WASH AFFECTED AREAS THOROUGHLY W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING & LAUNDER BEFORE RE-USE. EYES: FLUSH W/ WATER
FOR A MINIMUM OF 15 MINUTES. GET MEDICAL ATTENTION. INGEST: CALL
MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:199F,93C
Extinguishing Media:"ALCOHOL" FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER SPRAY MAY NOT BE EFTIVE. WATER MAY BE USED TO COOL CLOSED
CONTRS TO PVNT PRESS BUILD-UP (SUPP DATA)
Unusual Fire/Explosion Hazard:EXTREME HEAT MAY CAUSE CLOSED CONTAINERS
TO BURST.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DOL STORAGE CATEGORY 3B. USE ONLY
W/ADEQUATE VENTILATION. AVOID BREATHING VAPOR & SPRAY MIST. AVOID
CONTACT WITH SKIN & EYES.
Other Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE. TRANSFER ONLY
TO APPROVED CONTAINERS W/COMPLETE AND APPROPRIATE LABELING. DO NOT
TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, WEAR RESPIRATORY DEVICE APPROVED
BY NIOSH/MSHA.
Ventilation:LOCAL EXHAUST PREFERABLE, GENERAL EXHAUST ACCEPTABLE BELOW
TLV. REFER TO OSHA STANDARDS 1910.94, 1910.107, 1910.108.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USING. LAUNDER CONTAMINATED
CLOTHING BEFORE RE-USE.
Supplemental Safety and Health
FIRE FIGHT PROC: AND POSSIBLE AUTO IGNITION OR EXPLOSION WHEN EXPOSED
TO EXTREME HEAT.
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:1.2
pH:8.5-9
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:74.91
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:EXTREME HEAT AND OPEN FLAME.
Hazardous Decomposition Products:BY FIRE: CO2 AND CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS. DISPOSE OF I/A/W FEDERAL, STATE, AND
LOCAL REGULATIONS REGARDING POLLUTION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ADHESIVE 7054
Preparer's Name:BILL MCDONALD
CAGE:0FSN9
CAGE:0FSN9
============= Composition/Information on Ingredients =============
Ingred Name:PHENOL, POLYMER WITH FORMALDEHYDE, GLYCIDYL ETHER *97-2*
CAS:28064-14-4
Fraction by Wt: 10-20%
Ingred Name:REACTION PRODUCTS OF EPICHLOROHYDRIN & BISPHENOL A
*97-2*
CAS:25085-99-8
Fraction by Wt: 70-80%
Ingred Name:REFRACTORIES FIBERS, ALUMINOSILICATE
CAS:142844-00-6
Fraction by Wt: 0-5%
Ingred Name:AMORPHOUS FUMED SILICA, COLLOIDAL SILICON DIOXIDE,
AMORPHOUS SILICA DUST (IARC - GROUP 3) *97-2*
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 0-10%
Other REC Limits:20 MPPCF DUST IN AIR
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RATS): >5000 MG/KG
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: REPEATED EXPOSURE MAY CAUSE
IRRITATION/ALLERGIC REACTION. EYES: SLIGHT TRANSIENT TEMPORARY
IRRITATION. INGESTION: LOW SINGLE DOSE TOXICITY. SKIN
SENSITIZATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH FOR 15 MINS W/COPIOUS AMOUNTS OF WATER. SKIN:
IMMEDIATELY FLUSH W/PLENTY OF WATER FOR 15 MINS. INHALATION: REMOVE
TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN ALL CASES. NOTE TO
PHYSICIAN: NO SPECIFIC ANTIDOTE. SUPPORTIVE CARE. TREATMENT BASED
ON JUDGEMENT OF THE PHYSICIAN IN RESPONSE TO REACTIONS OF THE
PATIENT.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>424F
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS,
PRESSURE-DEMAND MSHA/NIOSH APPROVED & FULL FIRE PROTECTIVE
CLOTHING/GEAR.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP IN ABSORBENT SUCH AS SAND & COLLECT IN
SUITABLE CONTAINERS. RESIDUAL RESIN MAY BE REMOVED USING STEAM/HOT
SOAPY WATER. SOLVENTS ARE NOT RECOMMENDED FOR CLEANUP UNLESS
RECOMMENDED EXPOSURE GUID ELINES & SAFE HANDLING PRACTICES ARE
FOLLOWED.
======================Handling and Storage ======================
Other Precautions:PRACTICE GOOD CAUTION & PERSONAL CLEANLINESS TO AVOID
CONTACT W/SKIN/EYES. AVOID BREATHING VAPORS OF HEATED MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF HANDLING AT ELEVATED TEMPS W/O SUFFICIENT
VENTILATION, USE AN APPROVED, FULL FACE AIR PURIFYING RESPIRATOR.
Ventilation:USE ONLY W/ADEQUATE VENTILATION, LOCAL EXHAUST MAY BE
NECESSARY FOR SOME OPERATIONS.
Other Protective Equipment:FACESHIELD, FULL FACE RESPIRATOR, BODY
COVERING/CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:NONE
Appearance and Odor:GRAY, VISCOUS LIQUID W/FAINT EPOXY ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AMINES, BASES, ACIDS, OXIDIZING MATERIALS
Stability Condition to Avoid:EXCESS HEATING OVER LONG PERIODS OF TIME
DEGRADES THE RESIN.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION/PYROLYSIS OF
EPOXY RESINS: PHENOLICS, CO & WATER.
Conditions to Avoid Polymerization:QUANTITIES OF MORE THAN 1 POUND OF
PRODUCT PLUS AN ALIPHATIC AMINE WILL CAUSE IRREVERSIBLE
POLYMERIZATION W/HEAT BUILDUP
==================== Disposal Considerations ====================
Waste Disposal Methods:RESINS CAN BE DISPOSED OF BY
INCINERATION/LANDFILL IAW/LOCAL, STATE & FEDERAL REGULATIONS. DON'T
DUMP INTO ANY SEWERS, ON THE GROUND/INTO ANY BODY OF WATER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:C325 FIXER HARDENER-PART B
Kit Part:Y
Preparer's Name:NOT READABLE
CAGE:61803
CAGE:61803
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM SULFATE (SARA III)
CAS:10043-01-3
RTECS #:BD1700000
Fraction by Wt: 45.0%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ALUMINUM SULFATE (SARA III)
CAS:10043-01-3
RTECS #:BD1700000
Fraction by Wt: BALANCE
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:UNKNOWN Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:ACUTE:EYE AND SKIN IRRITATION-POSSIBLE
BURNS. CHRONIC:NOT KNOWN.
Effects of Overexposure:SKIN/EYES:IRRITATES & POSSIBLE BURNS; INGEST:
STOMACH PAIN
Medical Cond Aggravated by Exposure:NO DATA AVAILABLE
======================= First Aid Measures =======================
First Aid:EYES: WASH W/PLENTY OF WATER FOR 15 MIN; SKIN: WASH W/SOAP &
WATER; INGEST: SEEK IMMEDIATE MEDICAL ADVICE; GIVE FULL DETAILS OF
TOXICITY & AMOUNT SWALLOWED.
===================== Fire Fighting Measures =====================
Extinguishing Media:MFR STATES:"NONE"; USE MEDIA APPROPRIATE FOR
SURROUNDING FIR
Fire Fighting Procedures:WEAR SELF-CNTD BRTHG,APP H*20 SPRAY TO COOL
CONTR.
Unusual Fire/Explosion Hazard:MFR. STATES:"NONE"
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILLS: MOP UP ON TOWELLING & DISPOSE OF
IN PROPER CONTAINER; LARGE SPILLS: FLUSH TO AUTHORIZED DRAIN SITE
W/PLENTY OF WATER. LOCAL, STATE & FEDERAL REGULATIONS TAKE
PRECEDENCE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL CONTACT. KEEP
CONTAINERS TIGHTLY CLOSED
Other Precautions:NOT KNOWN
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MFR. STATES: "NONE REQUIRED"
Ventilation:NO SPECIAL REQUIREMENTS W ADEQUATE VENT.
Other Protective Equipment:MFR. STATES: "NOT REQUIRED"//EYE-WASH
FACILITY ADVISED.
Supplemental Safety and Health
KEY:Y01; PH OF SOLUTION:2.7 ; MSDS FM CLAYTON CHEM DATED:05/22/86;ITEM
IS A 6 PARTS KIT;THIS DESCRIBES:FIXER HARDENER PART B;SEE PNI A,&
C-F FOR OTHER PARTS; NO KNOWN CARCINOGEN IN THIS.
================== Physical/Chemical Properties ==================
HCC:C3
Boiling Pt:B.P. Text:212F/100C
Spec Gravity:1.2
pH:2.7
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR,COLORLESS LIQUID.NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MFR STATES: "NONE"
Stability Condition to Avoid:MFR STATES: "NONE KNOWN"
Hazardous Decomposition Products:MFR STATES: "NONE"
Conditions to Avoid Polymerization:WILL NOT POLYMERIZE
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH TO APPROVED DRAIN SITE W/PLENTY OF WATER
AS REGULATIONS PERMIT.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PH 4.00 BUFFER, 473651
CAGE:0JF84
CAGE:0JF84
============= Composition/Information on Ingredients =============
Ingred Name:NON HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT WITH SKIN OR EYES MAY CAUSE
SLIGHT IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:IMMEDIATELY FLUSH WITH LARGE AMOUNTS OF WATER FOR AT
LEAST 15 MINUTES . SKIN:WASH AFFECTED AREAS WITH SOAP AND WATER.
INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTIFICIAL
RESPI RATION) . INGEST:CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:MOP UP AFFECTED AREA. RINSE AREA WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID HIGH TEMPERATURES AND KEEP FROM
FREEZING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT APPLICABLE. NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Other Protective Equipment:LABORATORY PROTECTIVE CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Spec Gravity:1.02
Solubility in Water:COMPLETE
Appearance and Odor:RED LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE
FEDERAL, STATE AND LOCAL LAWS.
| 1 | gloves_mandatory |
=======================================================
Product ID: DEKA PRIMER, 1106
Cage: JO232
Box: 307
=======================================================
Contractor Summary
=======================================================
Cage: JO232
Box: 309
=======================================================
Ingredients
=======================================================
Cas: 1314-13-2
RTECS #: ZH4810000
% Wt: 5
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST; 9495
------------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Cas: 13463-67-7
RTECS #: XR2275000
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST; 9495
------------------------------
Cas: 7732-18-5
RTECS #: ZC0110000
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 7727-43-7
RTECS #: CR0600000
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST; 9495
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: AVOID CONTACT WITH EYES, MAY CAUSE EYE IRRITATION.
AVOID BREATHING PAINT MISTS. CHRONIC: CALIFORNIA PROP 65: THIS PRODUCT
CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER.
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYE:WASH CAREFULLY BUT IMMED WITH LARGE AMTS OF LUKEWARM WATER FOR
AT LEAST 15 MIN, OCCASIONALLY LIFTING THE UPPER & LOWER LIDS UNTIL NO
EVIDENCE OF MATERIAL REMAINS. IF DISCOMFORT OCCURS/IF REDNESS I S OBSERVED,
SEEK MED ATTN. SKIN:WASH WITH SOAP & WATER. SEEK MED ATTN IF IRRIT
OCCURS. INGEST:DRINK WATER OR MILK; CONSULT A MD. INHAL:REMOVE TO FRESH AIR.
IF BREATHING DIFFICULTY PERSISTS, CALL MD.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SPILLS SHOULD BE CONFINED & LIQ TAKEN UP W/ABSORB
MATLS & PLACED IN CNTNRS FOR PROPER DISP, WASTE DISP METH, SMALL QTIES
MAY BE POURED OUT ONTO PAPER, ALLOWED TO DRY, & DISPOSED OF W/NORMAL
SOLID WAST E. INDUSRIAL QTIES MUST BE DISPOSED OF (SUPDAT)
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS (FP N).
Handling And Storage Precautions: THIS PAINT IS INTENDED FOR PROFESSIONAL USE
ONLY. KEEP OUT OF THE REACH OF CHILDREN.
Other Precautions: WHENEVER WORKING W/SPECIAL MATL SUCH AS THIS PAINT, USERS
MUST TAKE DUE PREC TO PROTECT THEIR HLTH. AVOID INGEST/EYE CNTCT. AVOID
WIDESPREAD PRLNG SKIN CNTCT. PROVIDE VENT IF NEC TO REDUCE PAINT FUMES , USE
A NIOSH APPROVED MASK FOR (SUPDAT)
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: >200F,>93C
Extinguishing Media: WATER, DRY CHEMICAL, CO*2, FOAM.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE LIKELY.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF
CONCERN (FP N).
Ventilation: IF WORKING IN AN ENCLOSED AREA, USE LOCAL VENT TO REDUCE PAINT
FUMES WEAR NIOSH-APPRVD MASK FOR PAINT MISTS & (SUPDAT)
Other Protective Equipment: ANSI APPRVD EMER EYE WASH & DELUGE SHOWER (FP N).
IF USE IS LIKELY TO RESULT IN WIDESPREAD PROLONGED SKIN (SUPDAT)
Work Hygienic Practices: WASH HANDS BEFORE EATING.
Supplemental Safety and Health: PH: 8.5-9.0 SPILL PROC: IN ACCORDANCE WITH
EXISTING FEDERAL, STATE AND LOCAL ENVIRONMENTAL LAWS. OTHER PREC: PAINT MISTS
AND ORGANICS, IF THIS PRODUCT IS SPRAYED. VENT: ORGANICS IF VENTILATION IS
NOT POSSIBLE. OTHER PROT EQUIP: SKIN CONTACT, WEAR OTHER PROTECTIVE
CLOTHING.
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 1.481
VOC Pounds/Gallon: .3
PH: SUPDAT
VOC Grams/Liter: 35
Solubility in Water: DISPERSIBLE
Appearance and Odor: WHITE LIQUID (PAINT) AMMONIA/PAINT
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: AVOID TEMPERATURES ABOVE 350F.
Materials To Avoid: NONE KNOWN.
Hazardous Decomposition Products: THERMAL DECOMPOSITION MAY YIELD ACRYLIC
MONOMERS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: DEKA PRIMER, 1106
Cage: JO232
Assigned IND: Y
Company Name: DECART INC
Street: UNKNOWN
PO Box: 309
Zipcode: 05661
Label Required IND: Y
Date Of Label Review: 10/01/1996
Status Code: C
Label Date: 10/01/1996
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: Slight
Hazard And Precautions: THERMAL DECOMPOSITION MAY YIELD ACRYLIC MONOMERS.
ACUTE: AVOID CONTACT WITH EYES, MAY CAUSE EYE IRRITATION. AVOID BREATHING
PAINT MISTS. CHRONIC: CALIFORNIA PROP 65: THIS PRODUCT CONTAINS A CHEMICAL K
NOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FUEL OIL NO. 6
Preparer's Name:DELNO D. MALZAHN CIH
CAGE:0BDU2
CAGE:0BDU2
============= Composition/Information on Ingredients =============
Ingred Name:COMPLEX MIXTURE OR PARAFFINIC,OLEFINIC,NAPHTHENIC AN
AROMATIC HYDRO CARBONS
CAS:68553-00-4
Fraction by Wt: >99.0%
OSHA PEL:5MG/CUM,OIL MIST
ACGIH TLV:5MG/CUM,OIL MIST
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:ACUTE:IRRITATING TO EYES,SKIN,MUCOUS
MEMBRANES AND RESPIRATORY TRACT,CNS EFFECTS.DUE TO
INHALATION:HEADACHE,DIZZINESS,NAUSEA,VOMITING,LOSS OF
CO-ORDINATION.HARMFUL OR FATAL IF INGESTED. CHRONIC:DRYINGOF
SKIN,DERMATITIS.
Explanation of Carcinogenicity:MSDS STATES THAT MIDDLE DISTILLATES HAVE
CAUSED SKIN CANCER IN LABORATORY ANIMALS.
Effects of Overexposure:EYE:IRRITATIONSKIN:IRRITATION, DERMATITIS
INHALED:RESPIRATORY IRITATION, HEADACHE DIZZINESS, SYMPTOMS OF
INTOXICATION. INGESTED:MILD EXCITATION LOSS OF CONCIOUSNESS,
CONVULSIONS,CYANOSIS, CAPILLAR Y HEMORRHAGING OF INTERNAL ORGANS.
Medical Cond Aggravated by Exposure:MAY AGGRAVATE PRE-EXISTING
DERMATITIS.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WATER 15 MIN, HOLD LIDS OPEN. SKIN:WASH WITH SOAP
& WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE.
INHALED:REMOVE TO FRESH AIR. RESTORE BREATHING IF NECESSARY.
INGESTED:DO N OT INDUCE VOMITING. GIVE 2 LARGE GLASSES OF MILK OR
WATER AND GET IMMEDIATE MEDICAL CARE. DOCTOR TO ORDER VOMITING.
NOTHING BY MOUTH IF UNCONSCIOUS. IF IRRITATION PERSISTS OR IS
SEVERE,SEE A DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>140F/60C
Autoignition Temp:Autoignition Temp Text:765F
Lower Limits:1.0
Upper Limits:5.0
Extinguishing Media:DRY CHEMICAL,CO*2,FOAM & WATER SPRAY.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:FLOWING OIL CAN BE IGNITED BY SPARK FROM
SELF GENERATED STATIC ELECTRICITY.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;REMOVE ALL
IGNITION SOURCES;CONTAIN FREE LIQUID IF POSSIBLE;USE SUITABLE INERT
ABSORBENT MATERIAL AND RECOVER FOR PROPER DISPOSAL.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL DRY WELL VENTILATED
AREA. KEEP AWAY FROM SOURCES OF IGNITION. GROUND CONTAINERS WHEN
TRANSFERRING PRODUCT.
Other Precautions:'EMPTY' CONTAINERS MAY CONTAIN RESIDUE OR VAPOR.
TREAT THEM WITH THE RESPECT DUE FULL ONES. DO NOT CUT,WELD,ETC. ON
THEM. **DO NOT WEAR CONTACT LENSES.**
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC
VAPORS/MIST IF ABOVE PEL/TLV OR SCBA IN AN ENCLOSED AREA.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV.
Other Protective Equipment:IMPERVIOUS APRON;EYE-WASH FACILTIES.
Work Hygienic Practices:AVOID CONTACT WITH EYES AND SKIN;DO NO BREATHE
VAPORS/MIST;WASH THOROUGHLY AFTER EACH USE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:500F/260C
Melt/Freeze Pt:M.P/F.P Text:-20F
Vapor Pres:0.2
Vapor Density:8
Spec Gravity:0.97
Viscosity:<300 SFS
Evaporation Rate & Reference:0.01 (N-BUTYL ACETATE = 1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK LIQUID TO HEAVY PASTE;MILD PETROLEUM ODOR.
Percent Volatiles by Volume:NEGLIG
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENT.
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES,SPARKS AND OTHER
SOURCES OF IGNITION
Hazardous Decomposition Products:CO,CO*2,SO*2 AND HYDROCARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W ALL FEDERAL, STATE AND LOCAL
REGULATIONS. MANUFACTURER SUGGESTS THAT DISPOSAL MUST BE DONE BY A
LICENSED DISPOSAL FACILITY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ARGON
CAGE:0LV01
Contract Num:SP0440-98-M-K357
CAGE:76526
CAGE:0LV01
============= Composition/Information on Ingredients =============
Ingred Name:ARGON
CAS:7440-37-1
RTECS #:CF2300000
= Wt:100.
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:ASPHYXIANT; 9394
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV 0.5 MG/M3 (WELDING FUMES)
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: ASPHYXIANT. MODERATE
CONCENTRATIONS MAY CAUSE HEADACHE, DROWSINESS, DIZZINESS,
EXCITATION, EXCESS SALIVATION, VOMITING AND UNCONSCIOUSNESS. NOTE:
THERE ARE ADDITIONAL HEALTH HAZARDS WHEN P RODUCT IS USED IN
WELDING AND CUTTING.
Explanation of Carcinogenicity:THIS PRODUCT IS NOT LISTED BY IARC, NTP
OR OSHA AS A CARCINOGEN, MUTAGEN, TERATOGEN OR NEUROTOXIN.
Effects of Overexposure:HEADACHE, DROWSINESS, DIZZINESS, EXCITATION,
EXCESS SALIVATION, VOMITING AND UNCONSCIOUSNESS.
Medical Cond Aggravated by Exposure:A KNOWLEDGE OF THE AVAILABLE
TOXICOLOGICAL INFORMATION & THE PHYSICAL PROPERTIES SUGGEST THAT
OVEREXPOSURE IS UNLIKELY TO AGGRAVATE EXISTING MEDICAL CONDITIONS.
======================= First Aid Measures =======================
First Aid:SKIN: FLUSH WITH WATER. EYES: FLUSH WITH WATER. INHALATION:
REMOVE TO FRESH AIR. GIVE ARTIFICIAL RESPIRATION IF NOT BREATHING.
GIVE OXYGEN IF BREATHING IS DIFFICULT. CALL A PHYSICIAN. NOTE TO
PHYSICIA N: THIS PRODUCT IS INERT. THERE IS NO SPECIFIC ANTIDOTE.
TREATMENT OF OVEREXPOSURE SHOULD BE DIRECTED AT THE CONTROL OF
SYMPTOMS AND THE CLINICAL CONDITION.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:ARGON CANNOT CATCH FIRE. USE MEDIA SUITABLE FOR
SURROUNDING FIRE.
Fire Fighting Procedures:EVACUATE ALL PERSONNEL FROM DANGER AREA.
IMMEDIATELY COOL CONTAINERS WITH WATER SPRAY FROM SAFE DISTANCE.
SHUT OFF LEAK IF WITHOUT RISK.
Unusual Fire/Explosion Hazard:CONTAINER MAY RUPTURE DUE TO HEAT OF
FIRE. NO PART OF CONTAINER SHOULD BE SUBJECTED TO TEMPERATURE
HIGHER THAN 125F. MOST CONTAINERS ARE PROVIDED WITH A PRESSURE
RELIEF DEVICE DESIGNED TO VENT CONTENT S WHEN THEY ARE EXPOSED TO
ELEVATED TEMPERATURES.
================== Accidental Release Measures ==================
Spill Release Procedures:ARGON IS AN ASPHYXIANT. EVACUATE ALL PERSONNEL
FROM DANGER AREA. USE SELF CONTAINED BREATHING APPARATUS WHERE
NEEDED. SHUT OFF CYLINDER IF WITHOUT RISK. VENTILATE AREA OF LEAK
OR MOVE CYLINDER TO WELL VENTILATED AREA.
======================Handling and Storage ======================
Handling and Storage Precautions:CLOSE VALVE WHEN NOT IN USE AND WHEN
EMPTY. USE WITH EQUIPMENT RATED TO ADEQUATELY WITHSTAND PRESSURES
TO BE ENCOUNTERED.
Other Precautions:DO NOT GROUND CYLINDER. DO NOT STRIKE ARC ON
CYLINDER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE AIR PURIFYING OR AIR-SUPPLIED RESPIRATORS,
AS APPROPIATE, WHERE THE LOCAL NA/OR GENERAL EXHAUST VENTILATION IS
NOT ADEQUATE TO KEEP WORKER EXPOSURE BELOW THE APPLICABLE TLV'S
DURING WELDING OPERAT IONS USING ARGON. AIR SUPPLIED RESPIRATOTS
ARE REQUIRED WHILE WORKING IN CONFINED SPACES. THE RESPIRATORY
PROTECTION USE MUST COMPLY WITH OSHA RULES.
Ventilation:USE LOCAL EXHAUST SYSTEM, IF NECESSARY TO MAINTAIN
CONCENTRATION OF HAZARDOUS FUMES AND GASES BELOW APPLICABLE TLV'S.
Other Protective Equipment:AS NEEDED, WEAR HAND, HEAD AND BODY
PROTECTION WHICH HELP TO PREVENT INJURY FROM RADIATION, SPARKS AND
ELECTRICAL SHOCK.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
TRAIN WORKER NOT TO TOUCH LIVE ELECTRICAL PARTS.
================== Physical/Chemical Properties ==================
HCC:G3
Boiling Pt:=-185.8C, -302.6F
Melt/Freeze Pt:=-189.1C, -308.6F
Vapor Pres:GAS
Vapor Density:1.378
Spec Gravity:GAS
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS, ODORLESS GAS AT NORMAL TEMPERATURE AND
PRESSURE
Percent Volatiles by Volume:100 %
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE CURRENTLY KNOWN. ARGON IS CHEMICALLY INERT.
Stability Condition to Avoid:DO NOT STRIKE ARC ON CYLINDER. DO NOT
GROUND CYLINDER
Hazardous Decomposition Products:OZONE AND NITROGEN OXIDES MAY BE
FORMED BY RADIATION FROM THE ARC.
==================== Disposal Considerations ====================
Waste Disposal Methods:SLOWLY RELEASE INTO THE ATMOSPHERE. DISCARD ANY
PRODUCT, RESIDUE, DISPOSAL CONTAINER OR LINER IN AN ENVIORNMENTALLY
ACCEPTABLE MANNER, IN FULL COMPLIANCE WITH ALL FEDERAL, STATE AND
LOCAL REGULATIONS .
===================== Regulatory Information =====================
State Regulatory Information:THIS PRODUCT IS SUBJECT TO THE
PENNSYLVANIA WORKER AND COMMUNITY RIGHT-TO-KNOWN ACT (36 P.S.
SECTIONS 7301-7320).
======================= Other Information =======================
| 1 | gloves_mandatory |
=======================================================
NIIN: 00-550-5565
Product ID: MIL-C-14460-C TYPE I
Cage: 60797
=======================================================
Contractor Summary
=======================================================
Cage: 60797
=======================================================
Item Description Information
=======================================================
Item Manager: S9G
Item Name: CORROSION REMOVING COMPOUND
Specification Number: MIL-C-14460C
Type/Grade/Class: TYPE I
Unit of Issue: DR
Quantitative Expression: 00000000500LB
UI Container Qty: 1
Type of Container: DRUM
=======================================================
Ingredients
=======================================================
Cas: 1310-73-2
RTECS #: WB4900000
% Wt: UNKNOWN
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 2 MG/M3
ACGIH TLV: C 2 MG/M3; 9596
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: ORAL LD50 (RAT) IS UNKNOWN
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHALATION-INHALATION OF DUST OR MIST CAN CAUSE IRRITATION
AT 3 MG/M3. MORE SEVERE BURNS & TISSUE DAMAGE AT THE UPPER RESPIRATORY
TRACT. SKIN-CONTACT WITH SKIN CAN CAUSE SEVERE BURNS WITH DEEP ULCERAT IONS.
CONTACT WITH DUST CAN CAUSE MULTIPLE BURNS WITH TEMPORARY LOSS OF HAIR AT
BURN SITE.
Explanation Of Carcinogenicity: SODIUM HYDROXIDE IS NOT LISTED BY NTP, IARC OR
REGULATED BY OSHA AS A CARCINOGEN.
Signs And Symptions Of Overexposure: INGESTION-INGESTION CAN CAUSE SEVERE
BURNING & PAIN IN LIPS, MOUTH, TOUNGE, THROAT & STOMACH. SEVERE
SCARRING OF THE THROAT CAN OCCUR AFTER SWALLOWING. DEATH CAN OCCUR FRON
INGESTION. EYE-CAN CAUSE SE VERE DESTRUCTION AND BLINDNESS. MIST ORDUST CAN
CAUSE IRRITATION WITH HIGH CONCENTRATIONS CAUSING DESTRUCTIVE BURNS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYE CONTACT-FLUSH WITH WATER FOR 15 MINUTES & GET MEDICAL
ATTENTION. SKIN CONTACT-FLUSH EFFECTED AREA WITH WATER FOR AT LEAST 15
MINUTES. OBTAIN MEDICAL ATTENTION IF DISCOMFORT PERSISTS. REMOVE CONTAM
INATED CLOTHING. INHALATION-REMOVE TO FRESH AIR. IF DISCOMFORT PERSISTS GET
MEDICAL ATTENTION. INGESTION-DRINK LARGE QUANTITIES OF WATER TO DILUTE
CAUSTIC. DO NOT INDUCE VOMITING. GET MEDICAL AID.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: ONLY ALLOW TRAINED PERSONNEL WEARING APPROPIATE
SAFETY EQUIPMENT TO CLEAN UP SPILL. CONFINE SPILL TO SMALL AREA. CONFINE
SPILL. RECLAIM INTO CLOSED CONTAINER FOR DISPOSAL. REMAINING MATERIAL MAY BE
DI LUTED WITH WATER & NEUTRALIZED. PREVENTRUNOFF.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: SEND TO WASTE DISPOSAL SITE IN ACCORDANCE WITH LOCAL,
STATE AND FEDERAL LAWS.
Handling And Storage Precautions: STORE ON COOL DRY PLACE. STORE IN ORIGINAL
CONTAINER WITH LID TIGHTLY CLOSED. DO NOT CUT, MUTILATE, WELD, OR RE-USE THIS
CONTAINER.
Other Precautions: DANGER! STRONG ALKALINE PRODUCT CONTAINING CAUSTIC ALKALI.
CAUSES SEVERE BURNS TO SKIN AND EYES. DO NOT ALLOW TO CONTACT SKIN, EYES OR
CLOTHING.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONE
Autoignition Temp Text: NONE
Lower Limits: NONE
Upper Limits: NONE
Extinguishing Media: WATER, WATER SPRAY, WATER FOG, DRY CHEMICALS.
Fire Fighting Procedures: WEAR SELF-CONTAINED BREATHING APPARATUS AND FULL
PROTECTIVE EQUIPMENT AND CLOTHING.
Unusual Fire/Explosion Hazard: THIS PRODUCT MAY REACT WITH ALUMINUM, ZINC, TIN
AND THEIR ALLOYS TO PRODUCE FLAMMABLE HYDROGEN GAS.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF MIST, DUST OR SPRAY FROM THIS PRODUCT ARE PRESENT
WEAR NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation: USE ADEQUATE - LOCAL EXHAUST VENTILATION WHERE MIST, DUST OR PSRAY
FROM THIS PRODUCT MAY BE GENERATED.
Other Protective Equipment: TO PREVENT PROLONGED OR REPEATED SKIN CONTACT, WEAR
IMPERVIOUS SAFETY BOOTS AND CLOTHING.
Work Hygienic Practices: WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health: WHEN MIXING SOLUTION WITH GRANULAR PRODUCTS,
ADD PRODUCT SLOWLY ACROSS THE SURFACE OF THE SOLUTION TO PREVENT SPATTERING
OR LOCAL BOILING. USE RESPIRATOR IF NECESSARY. DO NOT ADD THIS PRODUCT TO HOT
W ATER.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: B1
Solubility in Water: COMPLETE
Appearance and Odor: OFF-WHITE GRANULAR - MILD ODOR.
Corrosion Rate: UNKNOWN
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE
Materials To Avoid: AVOID CONTACT WITH ZINC, TIN, ALUMINUM, AND ALL THEIR
ALLOYS.
Hazardous Decomposition Products: OXIDES OF CARBON AS WELL AS HYDROGEN GAS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NONE
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 76334
Product ID: MIL-C-14460-C TYPE I
Review Date: 03/19/1998
Tech Entry NOS Shipping Nm: SODIUM HYDROXIDE
Net Unit Weight: 500 LBS
AF MMAC Code: NR
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: DR
Container QTY: 1
Type Of Container: DRUM
Additional Data: PSN IS PER MFR MSDS.
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: DWZ
Symbols: G
DOT Proper Shipping Name: CORROSIVE SOLIDS, N.O.S.
Hazard Class: 8
UN ID Num: UN1759
DOT Packaging Group: II
Label: CORROSIVE
Packaging Exception: 154
Non Bulk Pack: 212
Bulk Pack: 240
Max Qty Pass: 15 KG
Max Qty Cargo: 50 KG
Vessel Stow Req: A
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ESJ
IMO Proper Shipping Name: CORROSIVE SOLID, N.O.S. o
IMDG Page Number: 8151
UN Number: 1759
UN Hazard Class: 8
IMO Packaging Group: I/II/III
Subsidiary Risk Label: -
EMS Number: 8-15
MED First Aid Guide NUM: 760
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: HMF
IATA UN ID Num: 1759
IATA Proper Shipping Name: CORROSIVE SOLID, N.O.S. *
IATA UN Class: 8
IATA Label: CORROSIVE
UN Packing Group: II
Packing Note Passenger: 814
Max Quant Pass: 15KG
Max Quant Cargo: 50KG
Packaging Note Cargo: 816
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: HMF
AFI Symbols: *
AFI Proper Shipping Name: CORROSIVE SOLID, N.O.S.
AFI Hazard Class: 8
AFI UN ID NUM: UN1759
AFI Packing Group: II
Special Provisions: P5
Back Pack Reference: A12.4
=======================================================
HAZCOM Label
=======================================================
Product ID: MIL-C-14460-C TYPE I
Cage: 60797
Company Name: VJ COMPOUNDING CORP (FORMALLY: L. CARLTON MERTZ CO.)
Street: 6147 W. 65TH STREET
Zipcode: 60638
Label Required IND: Y
Date Of Label Review: 03/19/1998
Status Code: C
Label Date: 03/19/1998
Origination Code: F
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Severe
Contact Hazard: Moderate
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: SPILL: ONLY ALLOW TRAINED PERSONNEL WEARING APPROPIATE
SAFETY EQUIPMENT TO CLEAN UP SPILL. CONFINE SPILL TO SMALL AREA. CONFINE
SPILL. RECLAIM INTO CLOSED CONTAINER FOR DISPOSAL. REMAINING MATERIAL MA Y BE
DILUTED WITH WATER & NEUTRALIZED. PREVENT RUNOFF. FIRST AID: EYE
CONTACT-FLUSH WITH WATER FOR 15 MINUTES & GET MEDICAL ATTENTION. SKIN
CONTACT-FLUSH EFFECTED AREA WITH WATER FOR AT LEAST 15 MINUT ES. OBTAIN
MEDICAL ATTENTION IF DISCOMFORT PERSISTS. REMOVE CONTAMINATED CLOTHING.
INHALATION-REMOVE TO FRESH AIR. IF DISCOMFORT PERSISTS GET MEDICAL ATTENTION.
INGESTION-DRINK LARGE QUANTITIES OF WAT ER TO DILUTE CAUSTIC. DO NOT INDUCE
VOMITING.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CLEAN (LOW HCL) PROPELLANT AAP-3658-1
CAGE:58339
CAGE:58339
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIUM PERCHLORATE
CAS:7790-98-9
RTECS #:SC7520000
Fraction by Wt: 38-50%
OSHA PEL:10 MG/CUM
ACGIH TLV:10 MG/CUM
Ingred Name:SODIUM NITRATE
CAS:7631-99-4
RTECS #:WC5600000
Fraction by Wt: 20-30%
Ingred Name:HYDROXY TERMINATED POLYBUTADIENE
CAS:69102-90-5
Fraction by Wt: 5-10%
Ingred Name:BIS(2-ETHYLHEXYL) ADIPATE (SARA III)
CAS:103-23-1
RTECS #:AU9700000
Fraction by Wt: 1-5%
Ingred Name:ISOPHORONE DIISOCYANATE (SARA III)
CAS:4098-71-9
RTECS #:NQ9370000
Fraction by Wt: 0.1-1.0%
Other REC Limits:0.005 PPM
OSHA PEL:S 0.005PPM/0.02STEL
ACGIH TLV:0.005 PPM; 9394
Ingred Name:URETHANE PREPOLYMER
CAS:9040-80-6
Fraction by Wt: 0.1-1.0%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IPDI IN UNCURED PROPELLANT MAY CAUSE
IRRITATION TO SKIN, EYES, & RESPIRATORY TRACT. SKIN: ALLERGIC
DERMATITIS, RASH, ITCHING, & SWELLING OF EXTREMITIES.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES/SKIN: IRRITATION, ALLERGIC DERMATITIS,
RASH, ITCHING, SWELLING OF EXTREMEITIES.
Medical Cond Aggravated by Exposure:DERMATITIS, RASH, ALLERGIC SKIN
REACTION.
======================= First Aid Measures =======================
First Aid:EYES: WASH W/WATER FOR 15 MINUTES. GET MED ATTN. SKIN: WASH
W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION: GET MED
ATTN.
===================== Fire Fighting Measures =====================
Extinguishing Media:SPRINKLER OR DELUGE SYSTEM ONLY. DON'T FIGHT
PROPELLANT FIRES.
Fire Fighting Procedures:DON'T ATTEMPT TO EXTINGUISH FIRES INVOLVING
SOLID PROPELLANT. EVACUATE AREA.
Unusual Fire/Explosion Hazard:BURNS VIGOROUSLY IF SUBJECTED TO FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP ALL SPILLS W/NON-SPARKING OR
NON-METALLIC TOOLS & RAGS DAMPENED W/1,1,1,-TRICHLORETHANE. WEAR
PROPER PERSONAL PROTECTIVE EQUIPMENT.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE W/CARE TO PREVENT EXPOSURE TO
FLAME, SPARK, IMPACT, FRICTION & HEAT >150F UNLESS
REVIEWED/APPROVED BY SAFETY ENGINEERING.
Other Precautions:ALL PROPELLANTS & EXPLOSIVES MUST HAVE A MINIMUM OF
ANTI-STATIC PLASTIC COVERING. PROPELLANT IS DESIGNED TO BURN
VIGOROUSLY AT TEMP5000F. CHIPS BURN AT EXCELLERATED RATE. IF
IGNITION IS PRESENT EVAC UATE AREA. CONFINEMENT CAUSES EXPLOSION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ORGANIC CARTRIDGE OR AIRLINE RESPIRATOR REQUIRED
FOR PROPELLANT HANDLING PROCEDURES. SUCH AS SCRAPE DOWN OF MIXING
BLADES, DURING MIXING OPERATIONS.
Ventilation:GENERAL ROOM VENTILATION IS ADEQUATE.
Other Protective Equipment:AS NECESSARY TO AVOID SKIN CONTACT.
Supplemental Safety and Health
ISOPHORONE DIISOCYANATE & C-I PREPOLYMER MAY BE ABSORBED INTO THE
BLOODSTREAM, THROUGH THE SKIN.
================== Physical/Chemical Properties ==================
Appearance and Odor:SOLID, GRAY, MILD SWEET HYDROCARBON
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
FLAMMABLE SOLVENTS
Stability Condition to Avoid:SPARKS, FLAMES, HEAT, IMPACT & FRICTION
Hazardous Decomposition Products:HCL, CO, CO2, NITROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:NORMALLY, THIS MATERIAL IS THERMALLY TREATED ON
SITE. CONTACT CENTRAL WASTE MANAGEMENT, FOR PROPER PROCEDURES &
CURRENT DISPOSAL METHODS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:GLYCERINE 10440 G153-1
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:GLYCERINE, 1,2,3,-TRIHYDROXYPROPANE, GLYCEROL, ANHYDROUS
GLYCERINE, GLYCERIN *97-1*
CAS:56-81-5
RTECS #:MA8050000
Fraction by Wt: 100%
ACGIH TLV:10 MG/CUM (VAPOR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 12,600 MG/KG GLYCERINE
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: MAY CAUSE IRRITATION.
INGESTION: GASTROINTESTINAL IRRITANT. INHALATION: RESPIRATORY
IRRITANT. MAY CAUSE KIDNEY INJURY.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, NAUSEA, VOMITING, DIARRHEA,
HEADACHE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR 15 MINS. SKIN: FLUSH
W/PLENTY OF SOAP & WATER FOR 15 MINS. INGESTION: IF CONSCIOUS &
ALERT, GIVE 2-4 CUPFULS OF MILK/WATER. NEVER GIVE ANYTHING BY MOUTH
IF UNCONSCIOU S. INHALATION: REMOVE TO FRESH AIR IMMEDIATELY. GIVE
CPR/OXYGEN IF NECESSARY. TREAT SYMPTOMATICALLY & SUPPORTIVELY.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:379.4F
Lower Limits:1.1
Extinguishing Media:WATER, DRY CHEMICAL, CHEMICAL
FOAM/ALCOHOL-RESISTANT FOAM
Fire Fighting Procedures:WEAR A SELF CONTAINED BREATHING APPARATUS IN
PRESSURE-DEMAND, MSHA/NIOSH APPROVED & FULL PROTECTIVE GEAR. USE
WATER SPRAY TO COOL FIRE-EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:AUTOIGNITION TEMP: 752F.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/INERT MATERIAL, DRY SAND/EARTH. THEN
PLACE INTO CHEMICAL WASTE CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA AWAY FROM INCOMPATIBLE SUBSTANCES. USE W/ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH APPROVED REPIRATOR WHEN NECESSARY.
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT TO CONTROL
AIRBORNE LEVELS.
Other Protective Equipment:PROTECTIVE CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
INCOMPATIBILITIES CONT'D: PERCHLORIC ACID, LEAD OXIDES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:554F
Melt/Freeze Pt:M.P/F.P Text:20F
Decomp Temp:Decomp Text:554F
Vapor Pres:0.0025
Vapor Density:3.17
Spec Gravity:1.4746
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR VISCOUS LIQUID W/BLAND ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, HYDROGEN PEROXIDE, POTASSIUM PERMANGANATE, CALCIUM
HYPOCHLORITE, NITRIC ACID, SULFURIC ACID (SEE SUPP)
Stability Condition to Avoid:EXCESSIVE HEAT, OTHER IGNITION SOURCES
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PERMACLAD HIGH SOLIDS BAKING ENAMEL NON-LEA
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:VENT:STANDARDS 1910.94, 1910.107, 1910.108.
RTECS #:9999999ZZ
Ingred Name:MINERAL SPIRITS. VP:2.
CAS:64742-47-8
Fraction by Wt: 0-5%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:XYLENE. VP:5.9.
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: <5%
OSHA PEL:100 PPM;150 PPM STEL
ACGIH TLV:100 PPM;150 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (LIGHT
AROMATIC NAPHTHA). VP:3.8
CAS:64742-95-6
Fraction by Wt: 10-20%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:ISOPROPYL ALCOHOL;(2-PROPANOL). (SARA III). VP:33.
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: <5%
OSHA PEL:400 PPM;500 PPM STEL
ACGIH TLV:400 PPM;500 PPM STEL
Ingred Name:FORMALDEHYDE (SARA III). VP:760.
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: <0.5%
OSHA PEL:SEE 1910.1048
ACGIH TLV:C 0.3 PPM; A2; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:ACETIC ACID, 2-METHOXY-1-METHYLETHYL
ESTER;(1-METHOXY-2-PROPANOL ACETATE). VP:1.8
CAS:108-65-6
RTECS #:AI8295000
Fraction by Wt: 0-5%
OSHA PEL:100 PPM;150 PPM STEL
ACGIH TLV:100 PPM;150 PPM STEL
Ingred Name:TITANIUM OXIDE;(TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 0-60%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:EFTS OF OVEREXP:AT 250 MG/M3 DEVELOPED LUNG CANCER,
HOWEVER, SUCH EXPOS LEVELS ARE NOT ATTAINABLE IN THE (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:WORKPLACE. REPORTS HAVE ASSOC RPTD/PRLNGD OVEREXP TO
SOLVS W/PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:CONC & INHALING CONTENTS CAN BE HARMFUL/FATAL.
THIS COATING MAY CNTN MATLS CLASSIFIED AS NUISANCE (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:PARTICULATES, SUCH AS TITANIUM DIOXIDE OR CALCIUM
CARBONATE, WHICH MAY BE PRESENT AT HAZ LEVELS ONLY (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:DURING SANDING/ABRADING OF DRIED FILM.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:PROD, UNDERLYING PAINT, OR THE ABRASIVE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE:IRRITATION OF EYES, SKIN & RESP
SYSTEM. MAY CAUSE NERVOUS SYSTEM DEPRESSION. EXTREME OVEREXPOSURE
MAY RESULT IN UNCONSCIOUSNESS & POSS DEATH. HEADACHE, DIZZ, NAUSEA
& LOSS OF COORDINATION ARE IN DICATIONS OF EXCESS EXPOS TO
VAPS/SPRAYMISTS. REDNESS/ITCHING OR BURNING SENSATION MAY INDICATE
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:FORMALDEHYDE:ANTIC CARCIN (NTP 6TH ANN
RPT, 91), IARC GP2A (IARC VOL7,P211,87), OSHA REG 29CFR1910.1048,
JUL 92 .
Effects of Overexposure:HLTH HAZ:EYE/EXCESS SKIN EXPOS.
CHRONIC:FORMALDEHYDE HAS BEEN SHOWN TO CAUSE CANCER OF NASAL CAVITY
IN RATS EXPOSED TO HIGH LEVELS. AVAIL EVIDENCE IS INCONCLUSIVE.
PRLNGD OVEREXP TO SOLV INGREDS MAY C AUSE ADVERSE EFTS TO LIVER,
URINARY, BLOOD FORMING, & REPROD SYS. RATS EXPOSED TO TITANIUM
DIOXIDE DUST (ING 8)
Medical Cond Aggravated by Exposure:MAY CAUSE ALLERGIC RESPIRATORY
AND/OR SKIN REACTION IN SUSCEPTIBLE INDIVIDUALS.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM &
QUIET. SKIN:WASH AFFECTED AREA THOROUGHLY WITH SOAP & WATER. REMOVE
CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE. EYE:FLUSH WITH
LARGE AMOUNT S OF WATER FOR AT LEAST 15 MINUTES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:105F,41C
Lower Limits:0.7%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL AND FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL PROT
EQUIP . WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZ
ARE PREF. WATER MAY BE USED TO COOL (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPARKS & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. APPLIC TO HOT (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTENTS ARE COMBUSTIBLE. KEEP AWAY
FROM HEAT & OPEN FLAME. CONSULT NFPA CODE. KEEP CONTAINER CLOSED
WHEN NOT IN USE. DO NOT TAKE INTERNALLY.
Other Precautions:USE ONLY W/ADEQ VENT. AVOID BRTHG VAP/SPRAY MIST.
AVOID SKIN/EYE CONTACT. USE APPROVED BONDING/GROUNDING PROC.
TRANSFER ONLY TO CONTAINERS WITH COMPLETE & APPROP LABELING. KEEP
OUT OF REACH OF CHILDRE N. INTENTIONAL MISUSE BY DELIB (ING 10)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERS EXPOS CANNOT BE CONTROLLED BELOW APPLIC
LIMITS BY VENT, WEAR NIOSH/MSHA APPROVED VAP/PARTICULATE RESP FOR
PROT. WHEN SANDING/ABRADING DRIED FILM, WEAR NIOSH/MSHA APPRVD
DUST/MIST RESP FOR DUST WHICH MAY BE GENERATED FROM (ING 13)
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPTABLE IF EXPOS TO MATLS IS
MAINTAINED BELOW APPLIC EXPOS LIMITS. REFER TO OSHA (ING 14)
Other Protective Equipment:BARRIER CREAM ON EXPOSED SKIN.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
MFR PT#/TRADE NAME:COLORS LEAD HAZARD FREE ORANGE, H67 E C9. FIRE
FIGHT PROC:CLSD CNTNRS TO PVNT PRESS BUILDUP & POSS AUTOIGNIT OR
EXPLO WHEN EXPOSED TO EXTREME HEAT. EXPLO HAZ:SURFS REQS SPECIAL
PRE CS. DURING EMERG CNDTNS OVEREXP TO DECOMP PRODS MAY CAUSE HLTH
HAZ. SYMPS MAY NOT BE IMMED APPARENT. GET MD.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:178F,81C
Vapor Pres:SEE ING
Vapor Density:HVR/AIR
Spec Gravity:1.03-1.8
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:28
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE:CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM PROD MAY BE HAZ AS DEFINED UNDER RCRA
40CFR261. WASTE MUST BE TESTED FOR IGNITABILITY TO DETERMINE APPLIC
EPA HAZ WASTE NUMBERS. INCIN IN APPRVD FACILITY. DO NOT INCIN CLSD
CNTNR. DISPOSE O F I/A/W FEDERAL, STATE & LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:COLORLOGIC CEMENT WITH FLUORIDE-BASE PASTE, 613731
CAGE:0JEB0
CAGE:0JEB0
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: MAY CAUSE IRRITATION AND
POSSIBLE CORNEAL DAMAGE. SKIN: MAY CAUSE DERMAL IRRITATION OR
POSSIBLE ALLERGIC REACTION. INDIVIDUALS WITH KNOWN SENSITIVITY TO
METHACRYLATES MAY SHOW ALLERGIC CO NTACT DERMATITIS. CHRONIC: NONE
SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARD.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH EYES WITH FLOWING WATER FOR AT LEAST 15 MINUTES.
CONSULT A PHYSICIAN. SKIN: FLUSH WITH FLOWING WATER FOR 15 MINUTES,
THEN WASH AFFECTED AREA WITH SOAP AND WATER. CALL A PHYSICIAN.
INGEST: CALL MD IMMEDIATELY . INHAL: REMOVE TO FRESH AIR. SUPPORT
BREATHING (GIVE O*2/ARTF RESP) .
===================== Fire Fighting Measures =====================
Extinguishing Media:CO*2, DRY CHEMICAL OR HALON.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:DURING A FIRE, IRRITATING GASSES FROM THE
DECOMPOSITION MAY BE PRESENT.
================== Accidental Release Measures ==================
Spill Release Procedures:SPREAD VERMICULITE ON PASTE TO ABSORB ANY
RESIN. SCOOP UP AND PLACE IN APPROPRIATELY MARKED CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM FOOD AND BEVERAGES.
STORE AWAY FROM EXTREME HEAT OR EXPOSURE TO VISIBLE LIGHT.
Other Precautions:OBSERVE NORMAL WAREHOUSE HANDLING PROCEDURES.
ECOLOGICAL INFORMATION: STABLE, ORGANIC LIQUID, DOES DEGRADE, DOES
NOT EVAPORATE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED DURING NORMAL USE. NIOSH APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL ESHAUST IS RECOMMENDED.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:OBSERVE NORMAL CARE WHEN WORKING WITH
CHEMICALS.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:1.8
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MULTI-COLORED PASTES WITH SWEET ACRYLIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
PEROXIDES.
Stability Condition to Avoid:HEAT GREATER THAN 60C.
Hazardous Decomposition Products:NOT APPLICABLE.
Conditions to Avoid Polymerization:HEAT GREATER THAN 70C. VISIBLE
LIGHT.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SCOTCHCAST BRAND ELECTRICAL RESIN 251 PART A
Kit Part:Y
CAGE:75037
CAGE:75037
Contract Num:SP0430-01-M-NG98
CAGE:0YSA1
============= Composition/Information on Ingredients =============
Ingred Name:BISPHENOL A-EPICHLOROHYDRIN POLYMER
CAS:25068-38-6
RTECS #:CE6880000
Minumum % Wt:55.
Maxumum % Wt:65.
Ingred Name:TALC
CAS:14807-96-6
RTECS #:WW2710000
Minumum % Wt:35.
Maxumum % Wt:45.
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:2 MG/M3
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
< Wt:1.
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:UNKNOWN IARC:YES
Health Hazards Acute and Chronic:EYE: MAY CAUSE EYE IRRITATION. MIXTURE
OF PART A AND PART B: SEVERELY IRRITATING TO THE EYES. SKIN:
ALLERGIC SKIN REACTION. MAY BE ABSORBED THROUGH THE SKIN AND
PRODUCE EFFECTS SIMILAR TO THOSE CAUSED BY INHALATION AND/OR
INGESTION. INHALATION: ALLERGIC RESPIRATORY REACTION. CENTRAL
NERVOUS SYSTEM DEPRESSION. UPPER RESPIRATORY TRACT IRRITATION.
INGESTION: IRRITATION OF GASTROINTESTINAL TISSUES.
Explanation of Carcinogenicity:CARBON BLACK IS LISTED BY IARC AS A
POSSIBLE HUMAN CARCINOGEN (GROUP 2B)
Effects of Overexposure:EYE: MAY CAUSE EYE IRRITATION. SKIN: CAN
INCLUDE REDNESS, SWELLING, BLISTERING, DRYNESS, AND ITCHING.
INHALATION: CAN INCLUDE DIFFICULTY BREATHING, WHEEZING, TIGHTNESS
OF CHEST, RESPIRATORY FAILURE, H EADACHE, DIZZINESS, DROWSINESS,
INCOORDINATION, SLOWED REACTION TIME, SLURRED SPEECH, GIDDINESS ,
SORENESS OF THE NOSE AND THROAT, COUGHING, SNEEZING, AND
UNCONSCIOUSNESS. INGESTION: CAN INCLUDE PAIN , VOMITING, ABDOMINAL
TENDERNESS, NAUSEA, BLOOD IN VOMITUS, AND BLOOD IN FECES.
======================= First Aid Measures =======================
First Aid:EYE: IMMEDIATELY FLUSH EYES WITH LARGE AMOUNTS OF WATER FOR
AT LEAST 15 MINUTES. GET IMMEDIATE MEDICAL ATTENTION. SKIN: FLUSH
SKIN WITH LARGE AMOUNTS OF WATER. IF IRRITATION PERSISTS, GET
MEDICAL ATTE NTION. INHALATION: IF SIGNS/SYMPTOMS OCCUR, REMOVE
PERSON TO FRESH AIR. IF SIGNS/SYMPTOMS CONTINUE, CALL A PHYSICIAN.
IF SWALLOWED: DRINK TWO GLASSES OF WATER. CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>148.9C, 300.F
Lower Limits:ND
Upper Limits:ND
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHNG, INCLUDING
HELMET, SELF-CONTAINED, POSITIVE PRESSURE OR PRESSURE DEMAND
BREATHING APPARATUS, BUNKER COAT AND PANTS, BANDS AROUND ARMS,
WAIST AND LEGS, FACE MASK, AND PROTE CTIVE COVERING FOR EXPOSED
AREAS OF THE HEAD.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:REFER TO OTHER SECTIONS OF THIS MSDS FOR
INFORMATION REGARDING PHYSICAL AND HEALTH HAZARDS, RESPIRATORY
PROTECTION, VENTILATION, AND PERSONAL PROTECTIVE EQUIPMENT. COVER
WITH ABSORBENT MATERIAL. COLLE CT SPILLED MATERIAL. CLEAN UP
RESIDUE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF THE REACH OF CHILDREN.
KEEP CONTAINER TIGHTLY CLOSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID BREATHING OF VAPORS. SELECT ONE OF THE
FOLLOWING NIOSH APPROVED RESPIRATORS BASED ON AIRBORNE CONCENTATION
OF CONTAMINANTS AND IN ACCORDANCE WITH OSHA REGULATIONS: HALF-MASK
ORGAIC VAPOR RESPIRA TOR.
Ventilation:USE WITH APPROPRIATE LOCAL EXHAUST VENTILATION.
Other Protective Equipment:USE ONE OR MORE OF THE FOLLOWING PERSONAL
PROTECTION ITEMS AS NECESSARY TO PREVENT SKIN CONTACT: APRON,
COVERALLS.
Supplemental Safety and Health
CURING OVENS MUST BE EXHAUSTED TO OUTDOORS OR TO A SUITABLE EMISSION
CONTROL DEVICE. PROVIDE SUFFICIENT VENTILATION TO MAINTAIN
EMISSIONS BELOW RECOMMENDED EXPOSURE LIMITS. IF EXHAUST VENTILATION
IS N OT ADEQUATE, USE APPROPRIATE RESPIRATORY PROTECTION. THIS IS
PART B OF 2 PART KIT, FOR PART B SEE MSDS# CLFBJ.
================== Physical/Chemical Properties ==================
HCC:V5
Melt/Freeze Pt:M.P/F.P Text:N/D
Spec Gravity:1.53
Viscosity:1750P
Solubility in Water:NIL
Appearance and Odor:BROWN VISCOUS LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE.
Conditions to Avoid Polymerization:HAZARDOUS POLYMEIZATION WILL NOT
OCCUR.
===================== Ecological Information =====================
Ecological:NOT DETERMINED.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN AN INDUSTRIAL OR COMMERICIAL
FACILITY. DISPOSE OF COMPLETELY ABSORBED WASTE PRODUCT IN A
SANITARY LAND FILL. DISPOSE OF COMPLETELY CURED (OR POLMERIZED)
MATERIAL IN A SANITARY LANDFILL. SINCE REGULATIONS VARY, CONSULT
APPLICABLE REGULATIONS OR AUTHORITIES BEFORE DISPOSAL.
=================== MSDS Transport Information ===================
Transport Information:NOT REGULATED BY ALL MODES OF TRANSPORTATION.
===================== Regulatory Information =====================
SARA Title III Information:RCRA HAZARD CLASS: ACUTE AND CHRONIC= YES;
PRESSURE AND REACTIVITY= NO.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CARGILL KINGSBURY-CLARK ALBUMIN STDS, 50 MG
CAGE:IO084
CAGE:10684
CAGE:IO084
============= Composition/Information on Ingredients =============
Ingred Name:FORMALDEHYDE (SARA III)
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: .30%
OSHA PEL:1 PPM;2 PPM STEL
ACGIH TLV:0.3 PPM A2, C
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:NONE KNOWN AT C.I.U. IF TUBES ARE
BROKEN OPEN, FORMALDEHYDE (O.3% OF GEL BY WEIGHT) VAPORS MAY
IRRITATE EYES AND NOSE. CONTACT MAY IRRITATE SKIN OR EYES.
INGESTION MAY IRRITATE MOUTH AND STOMACH.
Explanation of Carcinogenicity:FORMALDEHYDE:IARC MONOGRAPHS,
SUPPLEMENT, VOL.7, PG 211, 1987:GRP 2A. NTP 6TH ANNUAL RPT ON
CARCIN ANTIC TO BE CARCIN.
Effects of Overexposure:TUBES BROKEN OPEN; SLIPPERY GEL ON CLOTHES OR
BODY; IRRITATION OF EXPOSED AREA OF BODY.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INCLUDE POSSIBLE MATERIAL THAT MAY HAVE BEEN MIXED WITH
LIQUID DURING USE. INHAL:REMOVE TO FRESH AIR. SKIN:WASH WITH SOAP
AND WATER. EYES:FLUSH WITH WATER FOR AT LEAST 15 MINUTES-CONTACT
PHYSICIAN. IN GEST:CONTACT PHYSICIAN; IF CONSCIOUS, GIVE LARGE
AMOUNTS OF WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:122F,50C
Extinguishing Media:CARBON DIOXIDE
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB, PLACE IN PLASTIC CONTAINER, CAP OR
TWIST TIE CLOSURE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREAKING TUBES; MINIMIZE
EXPOSURE TO LIGHT, ESPECIALLY DIRECT SUN. STORE BETWEEN 50 AND 85
F.
Other Precautions:AVOID VAPORS, PROLONGED AND REPEATED SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NOT MANDATORY EXCEPT AS GOOD LABORATORY INDUSTRIAL
PRACTICES.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:ALWAYS USE GOOD HYGENIC WORK/PRACT. AS TO
HOUSEKEEPING, PERS HYGIENE, USE OF CHEM LAB APRON AND SPLASH
Supplemental Safety and Health
APPEAR/ODOR:CHARACTERISTIC ODOR IF OPENED.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:140F,60C
Vapor Pres:<24
Spec Gravity:1.16
Evaporation Rate & Reference:<1
Solubility in Water:VIRTUALLY COMPLETE
Appearance and Odor:VERY LIGHT TAN GEL SEALED IN GLASS TUBES W/EPOSY &
NATURAL CORK.SLIGHT(SUPPDATA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Conditions to Avoid Polymerization:HEAT, FLAME, SOURCES OF IGNITION,
POLYMERIZATION UNLIKELY AT CONCENTRATION USED.
==================== Disposal Considerations ====================
Waste Disposal Methods:ALL CHEMICAL DISPOSAL MUST BE IN ACCORDANCE WITH
LOCAL, STATE, AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:WKG SOL,KODAK COLOR DEVELOPER REPLENISHER, PROCESS E-6 AR
Preparer's Name:NOT PROVIDED
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM HYDROXIDE
CAS:1310-58-3
RTECS #:TT2100000
< Wt:.5
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH STEL:C2 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Minumum % Wt:90.
Maxumum % Wt:95.
Other REC Limits:NOT PROVIDED
Code:F
Code:F
Ingred Name:TRIPOTASSIUM PHOSPHATE
CAS:7778-53-2
RTECS #:TC8450000
Minumum % Wt:1.
Maxumum % Wt:5.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
Ingred
Name:4-(N-ETHYL-N-2-METHANESULFONYLAMINOETHYL)-2-METHYLPHENYLENEDIA
MINE SESQUISULFATE MONOHYDRATE
CAS:25646-71-3
RTECS #:PB0431000
Minumum % Wt:1.
Maxumum % Wt:5.
Other REC Limits:1 MG/M3 TWA; MFR
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
Ingred Name:SODIUM SULFITE
CAS:7757-83-7
RTECS #:WE2150000
< Wt:1.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT PROVIDED
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EFFECTS OF EXPOSURE: GENERAL: CONTAINS
4-(N-ETHYL-N-2-METHANESULFONYLAMINOETHYL)-2-METHYLPHENYLENEDIAMINE
SESQUISULFATE MONOHYDRATE. MAY CAUSE KIDNEY DAMAGE BASED ON ANIMAL
DATA. INHALATION: EXPECTEDTO BE A LOW HAZARD FOR RECOMMENDED
HANDLING. IN CONTACT WITH STRONG ACIDS OR IF HEATED, SULFITES MAY
LIBERATE SULFUR DIOXIDE GAS. SULFUR DIOXIDE GAS IS IRRITATING TO
THE RESPIRATORY TRACT. SOME ASTHM ATICS OR HYPERSENSITIVE
INDIVIDUALS MAY EXPERIENCE DIFFICULT BREATHING. EYES: CAUSES BURNS.
MIST IRRITATING. SKIN: CAUSES IRRITATION. MAY CAUSE ALLERGIC SKIN
REACTION. INGESTION: MAY BE HARMFUL IF SWA LLOWED.
Explanation of Carcinogenicity:CARCINOGENICITY CLASSIFICATION
(COMPONENTS PRESENT AT 0.1% OR MORE): - INTERNATIONAL AGENCY FOR
RESEARCH ON CANCER (IARC): NONE - AMERICAN CONFERENCE OF
GOVERNMENTAL INDUSTRIAL HYGIENISTS (ACGIH): SOD IUM BISULFITE, A4;
NOT CLASSIFIABLE AS A HUMAN CARCINOGEN. - NATIONAL TOXICOLOGY
PROGRAM (NTP): NONE - OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION
(OSHA):NONE
Effects of Overexposure:INHALATION: IN CONTACT WITH STRONG ACIDS OR IF
HEATED, SULFITES MAY LIBERATE SULFUR DIOXIDE GAS. SULFUR DIOXIDE
GAS IS IRRITATING TO THE RESPIRATORY TRACT. SOME ASTHMATICS OR
HYPERSENSITIVE INDIVIDUA LS MAY EXPERIENCE DIFFICULT BREATHING.
EYES: CAUSES BURNS. MIST IRRITATING. SKIN: CAUSES IRRITATION. MAY
CAUSE ALLERGIC SKIN REACTION.
Medical Cond Aggravated by Exposure:SOME ASTHMATICS, HYPERSENSITIVE OR
SULFITE-SENSITIVE INDIVIDUALS MAY EXPERIENCE DIFFICULT BREATHING,
WHEEZING, CHEST TIGHTNESS, STOMACH UPSET, HIVES, FAINTNESS,
WEAKNESS AND DIARRHEA.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. TREAT
SYMPTOMATICALLY. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. EYES:
IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. GET
MEDICAL ATTENTI ON IMMEDIATELY. SKIN: IMMEDIATELY FLUSH WITH PLENTY
OF WATER FOR AT LEAST 15 MINUTES WHILE REMOVING CONTAMINATED
CLOTHING AND SHOES. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: DO NOT INDUCE V OMITING. GIVE VICTIM A GLASS OF WATER.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. CALL A
PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SPILL WITH VERMICULITE OR OTHER INERT
MATERIAL, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN
SURFACE THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
Neutralizing Agent:NOT PROVIDED
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. KEEP AWAY FROM
INCOMPATIBLE SUBSTANCES (SEE INCOMPATIBILITY SECTION).
Other Precautions:DO NOT GET IN EYES. AVOID CONTACT WITH SKIN. AVOID
BREATHING MIST OR VAPOR. USE WITH ADEQUATE VENTILATION. WASH
THOROUGHLY AFTER HANDLING. THE ROUTINE USE OF A NONALKALINE (ACID)
TYPE OF HAND CLEANER AND REGULAR CLEANING OF WORKING SURFACES,
REACTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS DO NOT MAINTAIN AIRBORNE
CONCENTRATIONS BELOW RECOMMENDED EXPOSURE LIMITS, AN APPROVED
RESPIRATOR MUST BE WORN. RESPIRATOR TYPE: HALF-FACE CARTRIDGE
RESPIRATOR WITH HIGH EFFICI ENCY PARTICULATE AEROSOL (HEPA)
CARTRIDGES. IF RESPIRATORS ARE USED, A PROGRAM SHOULD BE INSTITUTED
TO ASSURE COMPLIANCE WITH OSHA STANDARD 29 CFR 1910.134.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER
HOUR) SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO
CONDITIONS.
APPROPRIATE FOR RISK OF EXPOSURE
FACE SHIELD.
Other Protective Equipment:EYE BATH, SAFETY SHOWER, WASHING FACILITIES
Work Hygienic Practices:NOT PROVIDED
Supplemental Safety and Health
SUPPLEMENTARY LOCAL EXHAUST VENTILATION, CLOSED SYSTEMS, OR RESPIRATORY
PROTECTION MAY BE NEEDED IN SPECIAL CIRCUMSTANCES SUCH AS POORLY
VENTILATED SPACES, EVAPORATION FROM LARGE SURFACES, SPRAYING, H
EATING, ETC.
================== Physical/Chemical Properties ==================
HCC:B3
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:>100.C, 212.F
Melt/Freeze Pt:M.P/F.P Text:NOT PROVIDED
Decomp Temp:Decomp Text:NOT PROVIDED
Vapor Pres:(68F):24 MBAR(18 MM HG)
Vapor Density:0.6
Spec Gravity:1.04
pH:12.0
Viscosity:NOT PROVIDED
Evaporation Rate & Reference:NOT PROVIDED
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS ODORLESS LIQUID.
Percent Volatiles by Volume:90- 95 WT
Corrosion Rate:NOT PROVIDED
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS
Stability Condition to Avoid:NOT PROVIDED
Hazardous Decomposition Products:NONE (NONCOMBUSTIBLE)
=================== Toxicological Information===================
Toxicological Information:DATA FOR
4-(N-ETHYL-N-2-METHANESULFONYLAMINOETHYL)-2-METHYLPHENYLENEDIAMINE
SESQUISULFATE MONOHYDRATE ACUTE TOXICITY DATA: ORAL LD-50 (MALE
RAT): 400 MG/KG (TARGET ORGAN EFFECTS: KIDNEY). ORAL LD-50
(FEMALE RAT): 246 MG/KG. DERMAL LD-50: > 1000 MG/KG (HIGHEST DOSE
TESTED). SKIN IRRITATION: SLIGHT.REPEATED SKIN APPLICATION:
MODERATE IRRITATION. SKIN SENSITIZATION: MODERATE. SKIN
SENSITIZATI ON (HUMAN): POSITIVE EYE IRRITATION (UNWASHED
EYES): MODERATE EYE IRRITATION (WASHED EYES): SLIGHT
===================== Ecological Information =====================
Ecological:THE FOLLOWING PROPERTIES ARE ESTIMATED FROM THE COMPONENTS
OF THE PREPARATIONS. POTENTIAL TOXICITY: FISH LC50 MG/L: >100.
DAPHNID EC50 MG/L: >100.ALGAL IC50 MG/L: >100. ORGANICS
READILY DEGRAD ABLE (>70%): YES (14 DAYS).POTENTIAL
BIOACCUMULATION: LOG POW <1. COD (APPROXIMATE G/L): 12. BOD5
(APPROXIMATE G/L): 2. POTENTIAL TOXICITY:WASTE TREATMENT
MICROORGANISMS EC50 (MG/L): >100.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL IS SUBJECT TO
NATIONAL, STATE, OR LOCAL LAWS. SINCE EMPTIED CONTAINERS RETAIN
PRODUCT RESIDUE, FOLLOW LABEL WARNINGS EVEN AFTER CONTAINER IS
EMPTIED. CONTRACT WITH A LICENSED CHEMICAL DISPOSAL AGENCY.
=================== MSDS Transport Information ===================
Transport Information:FOR TRANSPORTATION INFORMATION REGARDING THIS
PRODUCT CALL THE KODAK WORLDWIDE TRANSPORTATION HAZMAT HOT LINE:
(716) 722-2400 BETWEEN 8 A.M. AND 5 P.M. (EASTERN STANDARD TIME),
MONDAY THROUGH FRIDAY .
===================== Regulatory Information =====================
SARA Title III Information:CHEMICAL(S) SUBJECT TO THE REPORTING
REQUIREMENTS OF SECTION 313 OR TITLE III OF THE SUPERFUND
AMENDMENTS AND REAUTHORIZATION ACT (SARA) OF 1986 AND 40 CFR
PART 372: NONE
Federal Regulatory Information:NOT PROVIDED
State Regulatory Information:MATERIAL(S) KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER: NONE - MATERIAL(S) KNOWN TO THE STATE
OF CALIFORNIA TO CAUSE ADVERSE REPRODUCTIVE EFFECTS: NONE
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EN ALKYD SEMI-GLOSS LO VOC CT GRAY 36118, I
Preparer's Name:W. A. ELLISON
CAGE:61196
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:XYLENE (SOLVENT) (SARA III) (VAPOR PRESSURE 5 MM HG @ 20C)
(LFL 1.0; UFL 7.0)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/STEL 150 PPM
ACGIH TLV:100 PPM/STEL 150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SOLVENT NAPHTHA, LIGHT AROMATIC (SOLVENT)
CAS:64742-95-6
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
Ingred Name:N-BUTYL ACETATE (SOLVENT) (VAPOR PRESSURE 10 MM HG @ 20C)
(LFL 1.7; UFL 7.6)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM/STEL 200 PPM
ACGIH TLV:150 PPM/STEL 200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ISOAMYL KETONE (SOLVENT)
CAS:110-12-3
RTECS #:MP3850000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9293
Ingred Name:TOLUENE (SARA III) (VAPOR PRESSURE 22 MM HG @ 20C)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TITANIUM DIOXIDE (PIGMENT)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:METHYL ETHYL KETONE (SOLVENT) (SARA III) (VAPOR PRESSURE 70
MM HG @ 20C) (LFL 2.0; UFL 10.0)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/STEL 300 PPM
ACGIH TLV:200 PPM/STEL 300 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TALC (PIGMENT)
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 30%
Other REC Limits:NONE SPECIFIED
OSHA PEL:2 MG/M3, 20 MPPCF
ACGIH TLV:2 MG/M3, 15 MPPCF
Ingred Name:SILICA, CRYSTALLINE
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:SILICA, CRYSTALLINE - TRIPOLI
CAS:1317-95-9
RTECS #:VV7336000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:VOC: 3.08 LB/GAL LESS WATER & NEGLIGIBLY PHOTOCHEMICALLY
REACTIVE MATERIALS; 370 G/L LESS WATER; CALCULATED
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:UNKNOWN IARC:YES
Health Hazards Acute and Chronic:ACUTE; INGEST: GI IRRIT, NAUSEA,
VOMITING. ASPIRATION INTO LUNG MAY CAUSE CHEM PNEUMONITIS (CAN BE
FATAL). INHAL: NOSE OR THROAT IRRIT. ACUTE CENTRAL NERVOUS SYSTEM
DEPRESSION (HEADACHES, DIZZINESS, N AUSEA, CONFUSION). EYE: SEVERE
IRRIT, CORNEAL DAMAGE. SKIN: SKIN IRRIT. LIQUID MAY BE ABSORBED
THROUGH SKIN (HARMFUL).
Explanation of Carcinogenicity:IARC CONSIDERS CRYSTALLINE SILICA TO
HAVE LIMITED EVIDENCE OF CARCINOGENICITY IN HUMANS & SUFFICIENT IN
ANIMALS.
Effects of Overexposure:CHRONIC; SILICOSIS (LUNG DISEASE). LIVER,
KIDNEY, & BLOOD INJURY. INHANCE NEUROTOXICITY (SYNERGISTIC
EFFECT-PERIPHERAL NEUROPATHY IN HUMANS). REPORTS HAVE ASSOCIATED
PROLONGED OR REPEATED OVEREXPOSUR E TO SOLVENTS WITH PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE. CONCENTRATING/INHALING PRODUCT MAY
BE HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:PREEXISTING RESPIRATORY CONDITIONS
MAY BE AGGRAVATED BY EXPOSURE TO CRYSTALLINE SILICA.
======================= First Aid Measures =======================
First Aid:INGEST: DONT INDUCE VOMITING. CALL POISON CTR/EMERG ROOM/DR
IMMED. INHAL:REMOVE TO FRESH AIR IMMED. IF BREATHING STOPPED, GIVE
ARTIF RESPRTN. KEEP WARM & QUIET. GET MED AID IMMED. EYE: FLUSH
W/WATER 1 5 MIN, LIFTING EYELIDS. GET MED AID. SKIN: REMOVE CONTAM
CLOTHES. WASH AFFECTED AREA W/SOAP & WATER. GET MED AID IF IRRIT
PERSISTS. NOTE TO DR:DIRECT TREATMENT AT CLINICAL CONDITION &
SYMPTOM CONTROL.
===================== Fire Fighting Measures =====================
Flash Point:24.0F,-4.4C
Autoignition Temp:Autoignition Temp Text:572 F
Lower Limits:1.0
Upper Limits:10.0
Extinguishing Media:NFPA CLASS B EXTINGUISHERS (CO2, DRY CHEMICAL,
ALCOHOL FOAM) FOR FLAMMABLE LIQ. POLYMER FOAM PREFERRED FOR LARGE
FIRES.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE, USE TO COOL EXPOSED
CONTAINERS (FOG NOZZLES PREFERRED) TO PREVENT PRESSURE BUILDUP,
AUTOIGNITION OR EXPLOSION WHEN EXPOSED TO HEAT.
Unusual Fire/Explosion Hazard:DURING EMERGENCY CONDITION, OVEREXPOSURE
TO DECOMPOSITION PRODUCTS MAY BE HEALTH HAZARD. SYMPTOMS MAY NOT BE
IMMED. OBTAIN MEDICAL ATTENTION. WARNING FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR RSPRTR,EYE,HAND,BODY PROTECTN. KEEP
SPECTATORS AWAY. ELIMINATE IGNIT SOURCES. DIKE & CONTAIN W/INERT
MAT'L (SAND,EARTH,ETC). TRANSFER LIQ/USED ABSORBNT TO COVERED METAL
CONTAINER. USE NON-SPARKIN G TOOLS. PREVENT SEWER, GROUNDWATER
CONTAMINATION.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 115 F. STORE LARGE
QUANTITIES IN COMPLIANCE WITH OSHA 29 CFR 1910.106. DO NOT TAKE
INTERNALLY. DO NOT BREATHE SANDING DUST.
Other Precautions:CLOSE CONTAINER AFTER EACH USE. DO NOT WASH & REUSE
EMPTY CONTAINERS FOR ANY PURPOSE. GROUND & BOND CONTAINERS TO
RECEIVING CONTAINER. DONT WELD, BRAZE, OR CUT ON EMPTY CNTNR. NEVER
USE PRESSURE TO EM PTY. DRUM IS NOT A PRESSURE VESSEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTD,MAY NOT REQ RSPRTR.IN RESTRICTD
VENT,NIOSH CHEM CARTRIDGE RSPRTR MAY BE REQ'D.SPRAYNG,MECHAN
PREFILTER MAY ALSO BE REQ'D.CONFIND AREAS,USE AIR SUPPLD RSPRTR.SEE
OSHA 29CFR1910.134"RESP PROTEC T"&"RESP PROTECT-MANUAL &
GUIDELINE"AIHA
Ventilation:LOCAL EXHAUST VENT TO KEEP BELOW TLV. REMOVE DECOMPOSITION
PRODUCT. SEE "INDUST VENT-MANUAL RECOMMENDED PRACTICES" ACGIH
Other Protective Equipment:EYEWASH FACILITY, SAFETY SHOWER.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:139 TO 399F
Melt/Freeze Pt:M.P/F.P Text:-50F,-46C
Decomp Temp:Decomp Text:1832F,1000C
Vapor Pres:70 @ 68F
Vapor Density:> AIR
Spec Gravity:1.4
pH:4-7
Viscosity:67 - 77 KU
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Solubility in Water:SLIGHT IN WATER
Appearance and Odor:LIQUID, SOLVENT ODOR
Percent Volatiles by Volume:43
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS. OXIDIZING MATERIALS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT (>115F) AND SOURCES
OF IGNITION.
Hazardous Decomposition Products:BURNING, INCLUDING WHEN HEATED BY
WELDING OR CUTTING, WILL PRODUCE SMOKE, CARBON MONOXIDE & CARBON
DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE &
LOCAL LAWS OR REGULATIONS. INCINERATE IN EPA PERMITTED FACILITY.
DONT INCINERATE CLOSED CONTAINERS. OBSERVE PRECAUTIONS FOR DISPOSAL
OF FLAMMABLE MATERIALS. RCRA CLASSIFICATION: D001.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PERMOUNT SOLUTION;CAT#SP15100
Preparer's Name:GASYON L.PILLORI
CAGE:22527
CAGE:22527
============= Composition/Information on Ingredients =============
Ingred Name:PINENE RESIN(ALPHA PINENE)
CAS:80-56-8
RTECS #:DT7000000
Fraction by Wt: 57.4%
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 41.6%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:2,6-DI-TERT-BUTYL-P-CRESOL
CAS:128-37-0
RTECS #:GO7875000
Fraction by Wt: 1.0%
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3; 9192
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: OVEREXPOSURE MAY LEAD TO
CENTRAL NERVOUS SYSTEM DEPRESSION, LEADING TO IRRITATION, HEADACHE,
NAUSEA, DIZZINESS, FATIGUE, CONFUSION AND UNCONSCIOUSNESS. EYE: MAY
LEAD TO IRRITATION. SKIN: MAY LE AD TO DERMATITIS.HARMFUL IF
SWALLOWED OR INHALED.CNS DEPRESSION;IRRITATION OF MUCOUS
MEMBRANES,EYES OR SKIN.
Explanation of Carcinogenicity:DATA PER MSDS
Effects of Overexposure:OVEREXPOSURE MAY LEAD TO RESPIRATORY
IRRITATION, NAUSEA, FATIGUE, DIZZINESS, HEADACHES, UNCONSCIOUSNESS,
DERMATITIS AND EYE IRRITATION.
Medical Cond Aggravated by Exposure:PERSONS WITH A SKIN DISORDER SHOULD
USE CAUTION WHEN HANDLING OR USING THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:SKIN: REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER.
GET MEDICAL ATTENTION IF IRRITATION PERSISTS. INHALATION: REMOVE TO
FRESH AIR & RESTORE BREATHING IF NECESSARY. GET MEDICAL ATTENTION.
EYE : IMMEDIATELY FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING
EYELIDS OPEN. GET MEDICAL ATTENTION. INGESTION: GET IMMEDIATE
MEDICAL ATTENTION. DO NOT INDUCE VOMITING. NOTHING BY MOUTH IF
UNCONSCIOUS.
===================== Fire Fighting Measures =====================
Flash Point:45.0F,7.2C
Lower Limits:1.4
Upper Limits:6.7
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:MINOR: ABSORB MATERIAL WITH CLAY, VERMICULITE,
OR SIMILAR ABSORBENT MATERIAL. PLACE IN DISPOSAL CONTAINERS. MAJOR:
DIKE & CONTAIN SPILL. ELIMINATE SOURCES OF IGNITION. SHUT OFF
LEAKS. REMOVE LIQUID BY VACUUM OR ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, VENTILATED WORK AREA.
KEEP CONTAINERS CLOSED WHEN NOT IN USE. FLAMMABLE LIQUID, EMPTY
CONTAINERS CAN BE HAZARDOUS.
Other Precautions:THE SELECTION OF PERSONAL PROTECTIVE EQUIPMENT SHOULD
BE MADE BY THE MATERIAL USER BASED ON THE PARTICULAR CONDITIONS
WHERE THE MATERIAL IS TO BE USED TOGETHER WITH INFORMATION
CONTAINED IN THIS MSDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR. AIR-SUPPLIED
OR FILTERING TYPE WITH ORGANIC VAPOR CARTRIDGES ARE RECOMMENDED.
Ventilation:LOCAL AND MECHANICAL EXHAUST RECOMMENDED. AVOID OPEN
ELECTRICAL SOURCES NEAR PRODUCT VAPOR AREAS.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER.
Work Hygienic Practices:DO NOT TAKE INTERNALLY. AVOID SKIN CONTACT.
WASH SKIN AFTER USING PRODUCT. DO NOT EAT, DRINK OR SMOKE IN WORK
AREA.
Supplemental Safety and Health
AVOID CONTACT WITH EYES AND SKIN;DO NOT BREATHE VAPORS/MIST.
================== Physical/Chemical Properties ==================
HCC:F2
Spec Gravity:0.93
Evaporation Rate & Reference:>1 (ETHER)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:YELLOW LIQUID
Percent Volatiles by Volume:40
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
OTHER HYDROCARBON COMPOUNDS DURING COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MAY BE BURNED IN AN APPROVED INCINERATOR
OR DISPOSED OF IN ACCORDANCE WITH ALL APPLICABLE LOCAL, STATE AND
FEDERAL LAWS AND REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:C495-500/COPPER SULFATE ANHYDROUS 05670
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:COPPER SULFATE, BASIC
CAS:7758-98-7
RTECS #:GL8800000
Fraction by Wt: >97%
ACGIH TLV:1 MG/CUM (CU)
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 300 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION, CONJUNCTIVITIS,
ULCERATION, CORNEAL ABNORMALITIES & DEATH. SKIN: IRRITATION &
BURNING. INGESTION: GI IRRITATION, LIVER DAMAGE & DEATH.
INHALATION: RESPIRATORY TRACT IRRITATION, ULCER ATION & PERFORATION
OF THE NASAL SEPTUM. COPPER MAY DAMAGE LIVER, KIDNEYS, BRAIN,
BLOOD, BONES & ENDOCRINE GLANDS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INFLAMMATION, IRRITATION, HYPOTENSION,
JAUNDICE, COMA, BURNS, PAIN, ITCHING, REDNESS, NAUSEA, VOMITING,
DIARRHEA.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR 15 MINS. SKIN: FLUSH
W/PLENTY OF SOAP & WATER FOR 15 MINS. INGESTION: IF CONSCIOUS &
ALERT, GIVE 2-4 CUPFULS OF MILK/WATER. INDUCE VOMITING BY GIVING 1
TSP OF SYRUP O F IPECAC. INHALATION: REMOVE TO FRESH AIR. GIVE
CPR/OXYGEN IF NEEDED. NOTES TO PHYS: TREAT SYMPTOMATICALLY &
SUPPORTIVELY. PENICILLAMINE MAY BE OF VALUE AS A CHELATING AGENT.
(SEE SUPP)
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, DRY CHEMICAL/CO2.
Fire Fighting Procedures:WEAR SCBA IN PRESSURE DEMAND MSHA/NIOSH
APPROVED/EQUIVALENT & FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:NON-COMBUSTIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR A SCBA & APPROPRIATE PERSONAL PROTECTION.
SWEEP UP, THEN PLACE INTO A SUITABLE CLEAN, DRY CONTAINER FOR
DISPOSAL. AVOID GENERATING DUSTY CONDITIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A TIGHTLY CLOSED CONTAINER.
STORE IN A COOL, DRY , WELL VENTILATED AREA AWAY FROM INCOMPATIBLE
SUBSTANCES. USE ADEQUATE VENTILATION.
Other Precautions:DON'T INGEST/INHALE. DON'T GET ON SKIN/EYES. MINIMIZE
DUST GENERATION & ACCUMULATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH APPROVED RESPIRATOR WHEN NECESSARY.
Ventilation:GENERAL/LOCAL EXHAUST TO KEEP AIRBORNE CONCENTRATIONS BELOW
EXPOSURE LIMITS.
Other Protective Equipment:PROTECTIVE CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
FIRST AID CONT'D: OBTAIN MEDICAL ATTENTION IN ALL CASES.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:176F
Vapor Pres:NEGLIGIBLE
Spec Gravity:3.6
Solubility in Water:COMPLETE
Appearance and Odor:SOLID BLUE CRYSTALS/POWDER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE MATERIALS, HYDROXYLAMINE.
Stability Condition to Avoid:HIGH TEMPS
Hazardous Decomposition Products:OXIDES OF SULFUR, COPPER FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NI-171 (PRODUCT CODE 036065-05)
Preparer's Name:MICHELLE ALEXANDER
CAGE:0FGH2
CAGE:0FGH2
Contract Num:SP0490-95-D-4037
CAGE:0VYG8
============= Composition/Information on Ingredients =============
Ingred Name:COBALT
CAS:7440-48-4
RTECS #:GF8750000
Minumum % Wt:20.
Maxumum % Wt:50.
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.02 MG/M3
Ingred Name:NICKEL
CAS:7440-02-0
RTECS #:QR5950000
Minumum % Wt:20.
Maxumum % Wt:50.
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:CHROMIUM
CAS:7440-47-3
RTECS #:GB4200000
Minumum % Wt:5.
Maxumum % Wt:20.
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ALUMINIUM
CAS:7429-90-5
RTECS #:BD0330000
Minumum % Wt:5.
Maxumum % Wt:20.
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:YTTRIUM
CAS:7440-65-5
RTECS #:ZG2980000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE- SKIN: MAY CAUSE ALLERGIC
DERMATITIS. MAY CAUSE ULCERS. EYES: MAY CAUSE IRRITATION.
INGESTION: MAY CAUSE NERVOUS SYSTEM DEPRESSION. INHALATION: MAY
CAUSE RESPIRATORY TRACT IRRITATION. MAY ALSO C AUSE INTERSTITIAL
PNEUMONITIS & SENSITIZATION OF THE RESPIRATORY TRACT IN SUSCEPTIBLE
INDIVIDUALS. CHRONIC- MAY CAUSE SENSITIZATION IN SUSCEPTIBLE
INDIVIDUALS. EYES: CAN CAUSE CORNEAL DAMAGE, POLYCYTH EMIA,
HYPERPLASIA OF THE THYROID GLAND, & DAMAGE TO THE ALPHA CELLS OF
THE PANCREAS. INHALATION: MAY CAUSE EMPHYSEMA OR PULMONARY FIBROTIC
DISEASE.
Explanation of Carcinogenicity:NICKEL IS LISTED AS A PROBABLE HUMAN
CARCINOGEN. CHROMIUM IS LISTED AS A HUMAN CARCINOGEN. NICKEL &
CHROMIUM HAVE BEEN DETERMINED TO CAUSE CANCER IN EXPERIMENTAL
ANIMALS (IARC, NTP).
Effects of Overexposure:SKIN-MAY CAUSE ALLERGIC DERMATITIS, WITH
REDNESS & PAPULAR FORMATION IN SUSCEPTIBLE INDIVIDUALS, WHICH
USUALLY OCCURS IN THE FOLDS OF THE SKIN. MAY CAUSE ULCERS
PROGRESSING TO DRY & SCALY SKIN, FEVER . EYE-MAY CAUSE IRRITATION,
EXPERIENCED AS REDNESS & EXCESS REDNESS OF THE CONJUNCTIVA.
SWALLOWING-MAY CAUSE NAUSEA, ABDOMIAL PAIN, VOMITING, DIARRHEA, CNS
DEPRESSION, & BURNING SENSATION. INHALATION- MAY CAUSE RESPIRATORY
TRACT IRRITATION, WITH CHEST PAIN, VOMITING, DIARRHEA, BURNING
SENSATION, & CNS DEPRESSION.
Medical Cond Aggravated by Exposure:BREATHING OF DUST MAY AGGRAVATE
ASTHMA AND INFLAMMATORY OR FIBROTIC PULMONARY DISEASE. MAY ALSO
AGGRAVATE AN EXISTING DERMATITIS.
======================= First Aid Measures =======================
First Aid:SWALLOWING-GIVE AT LEAST 2 GLASSES OF MILK OR WATER. INDUCE
VOMITING, UNLESS PATIENT IS UNCONSCIOUS. CALL A PHYSICIAN.
SKIN-WASH THOROUGHLY WITH SOAP AND WATER. INHALATION-REMOVE TO
FRESH AIR. GIVE AR TIFICIAL RESPIRATION IF NOT BREATHING. OXYGEN
MAY BE GIVEN IF NECESSARY. CALL A PHYSICIAN. EYES-FLUSH THOROUGHLY
WITH PLENTY OF WATER. IF DISCOMFORT PERSISTS, SEEK MEDICAL
ATTENTION, PREFERABLY AN OPT HALMOLOGIST.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:USE SPECIAL DRY POWDER METAL EXTINGUISHING MATERIAL
TO EXTINGUISH METAL FIRES. USE APPROPRIATE EXTINGUISHER TO
EXTINGUISH COMBUSTABLE MATERIALS THAT MAY BE IGNITED BY THERMAL
FLAME.
Fire Fighting Procedures:CONSULT AND COMPLY WITH ANSI Z49.1 SAFETY IN
WELDING AND CUTTING, NFPA51B STANDARD FOR FIRE PREVENTION IN USE OF
CUTTING AND WELDING PROCESSES. NFPA51 OXYGEN-FUEL GAS SYSTEMS FOR
WELDING AND CUTTING, AND NFPA58 STANDARD FOR THE STORAGE AND
HANDLING OF LIQUIFIED PETROLEUM GASES.
Unusual Fire/Explosion Hazard:AIRBORNE DUST PARTICLES, ESPECIALLY METAL
DUST, AND ACCUMULATION OF SUCH SHOULD BE TREATED AS EXPLOSIVES. TO
MINIMIZE DANGER FROM DUST EXPLOSIONS, ADEQUATE VENTILATION SHOULD
BE PROVIDED TO SPRAY BOOT H IN ACCORDANCE WITH AMERICAN WELDING
SOCIETY PUBLICATION AWSC2.1-73, AND ACGIH PUBLICATION "INDUSTRIAL
VENTILATION".
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT TO PROTECT AGAINST
HAZARDS AND DISPOSE OF PER WASTE DISPOSAL METHOD.
======================Handling and Storage ======================
Other Precautions:CAUTION: WHEN THERMAL SPRAYING - ELECTRICITY CAN
CAUSE FATAL SHOCK! DO NOT TOUCH LIVE ELECTRICAL PARTS! ARC RAYS CAN
BURN EYES AND SKIN! WEAR RECOMMENDED EYE AND BODY PROTECTION.
FUMES, GAS, & DUST CA N HARM YOUR HEALTH. PROVIDE ENOUGH
VENTILATION AND WEAR RESPIRATORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DEPENDS UPON SPECIFIC USE, CONDITION, AND
LOCATION. IF THERE IS DUSTINESS, WEAR RESPIRATOR SELECTED PER OSHA
1910.134, AND OSHA 29 CFR 1910.252 AND ANSI Z49.1
Ventilation:LOCAL DUST PICK UP AND VENTILATION RECOMMENDED.
Other Protective Equipment:SEE ANSI Z49.1, ANSI Z87.1, ANSI Z88.2 FOR
Supplemental Safety and Health
CAUTION: WHEN THERMAL SPRAYING-ELECTRICITY CAN CAUSE FATAL SHOCK! DO
NOT TOUCH LIVE ELECTRICAL PARTS! ARC RAYS CAN BURN EYES AND SKIN!
WEAR RECOMMENDED EYE ANDBODY PROTECTION. FUMES, GAS, AND DUST CAN
HARM YOUR HEALTH. PROVIDE ENOUGH VENTILATION AND WEAR
RESPIRATORS.(OTHER INFO)
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NONE
Vapor Density:N/VOLATILE
Appearance and Odor:DUSTY YELLOW GRAY POWDER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
Hazardous Decomposition Products:WHEN THERMAL SPRAYING, DECOMPOSITION
PRODUCTS WILL VARY WITH OPERATING CONDITIONS. DECOMPOSITION
PRODUCTS OF NORMAL OPERATION FROM THIS THERMAL SPRAY POWDER
(OXIDES, SUB-OXIDES, ETC)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE PERS LOCAL, STATE, AND FEDERAL
REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:PROPER SHIPPING NAME: METAL ALLOY POWDER NOI ITEM
136500 SUB 1.
===================== Regulatory Information =====================
SARA Title III Information:7440-48-4, COBALT, <50 PERCENT BY WEIGHT.
7440-02-0, NICKEL, <50 PERCENT BY WEIGHT . 7440-47-3, CHROMIUM, <50
PERCENT BY WEIGHT.
Federal Regulatory Information:ALL INGREDIENTS IN THIS PRODUCT ARE
LISTED IN THE T.S.C.A. INVENTORY.
State Regulatory Information:PROP 65 (CARCINOGEN): WARNING: THIS
PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO
CAUSE CANCER. CAS #7440-02-0, NICKEL; CAS #7440-47-3, CHROMIUM.
======================= Other Information =======================
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:FA10986A
CAGE:JO867
CAGE:81831
CAGE:JO867
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR. AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UN CONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SALT BRIDGE SOLUTION, 380006.001
CAGE:0ERJ7
CAGE:63404
CAGE:0ERJ7
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM CHLORIDE
CAS:7447-40-7
RTECS #:TS8050000
Fraction by Wt: 8.9%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHYLENE GLYCOL (SARA 313) (CERCLA)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 11.1%
OSHA PEL:N/K
ACGIH TLV:C 50 PPM, VAPOR
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: IRRITATION,
ALLERGIC REACTION AS A RESULT OF PRESERVATIVE. EYES/SKIN:
IRRITATION, SENSITIZATION, ALLERGIC REACTION AS A RESULT OF
PRESERVATIVE. INGESTION: HEADACHE, VOMITING, CYANOS IS,
HYPERTENSION, AMNESIA AND COMA MAY BE EXPERIENCED IF INGESTED.
CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
OXYGEN OR ARTIFICIAL RESPIRATION) . EYES: IMMEDIATELY FLUSH WITH
PLENTY OF WATER FOR AT LEAST 15 MINUTES. CONSULT MD. SKIN:
IMMEDIATELY W ASH SKIN WITH SOAP AND PLENTY OF WATER.INGESTION: IF
SWALLOWED, INDUCE VOMITING IMMEDIATELY BY GIVING TWO GLASSES OF
WATER AND STICKING FINGER DOWN THROAT. CALL MD.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE.
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:IF LIQUID MATERIAL SPILLS, ABSORB ON HAZORB
PILLOWS OR OTHER ABSORBENT. SEAL IN PLASTIC BAG. LABEL. DISPOSE PER
LOCAL GUIDELINES. WASH SITE OF SPILL WITH SOAPY WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PER PRODUCT INSERT SHEET.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL PRECAUTIONS. USE NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NO SPECIAL PRECAUTIONS.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PH: 7.45 +/- 0.2.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Vapor Pres:18 @ 25C
Vapor Density:0.6
Spec Gravity:1.01
pH:SUPDAT
Evaporation Rate & Reference:1 (WATER=1)
Solubility in Water:AQUEOUS
Appearance and Odor:CLEAR, COLORLESS, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ETHYLENE GLYCOL MONOMETHYL ETHER, NC9476220
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:2-METHOXYETHANOL; (ETHYLENE GLYCOL MONOMETHYL ETHER).
LD50:(ORAL,RAT) 2370 MG/KG. NIOSH: 0.1 PPM TWA; 0.3 MG/M3 TWA 200
PPM IDLH (NOT APPLICABLE BECAUSE OF NIOSH REL). EINECS/ELINCS:
203-713-7.
CAS:109-86-4
RTECS #:KL5775000
> Wt:98.
OSHA PEL:80 MG/M3;25 PPM
ACGIH TLV:16 MG/M3;5 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT & TOXICOLOGICAL INFO.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: MAY CAUSE MODERATE
IRRITATION. MAY CAUSE TRANSIENT CORNEAL INJURY. SKIN: MAY BE
ABSORBED THROUGH SKIN IN HARMFUL AMOUNTS. IF ABSORBED, CAUSES
SYMPTOMS SIMILAR TO THOSE OF INGESTION. INGEST ION: CAUSES
DIGESTIVE TRACT IRRITATION. MAY CAUSE LIVER AND KIDNEY DAMAGE.
EXPOSURE MAY CAUSE ANEMIA AND BLOOD ABNORMALITIES. MAY CAUSE
CENTRAL NERVOUS SYSTEM DEPRESSION. INHALATION: MAY CAUSE RESPIRA
TORY TRACT IRRITATION. MAY CAUSE LIVER AND KIDNEY DAMAGE. MAY CAUSE
DYSPNEA (DIFFICULT BREATHING FROM SHORTNESS OF BREATH. CHRONIC: MAY
CAUSE BONE MARROW ABNORMALITIES WITH DAMAGE TO BLOOD FORMING TIS
SUES. MAY CAUSE ANEMIA(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT LISTED BY ACGIH, IARC, NIOSH, NTP OR
OSHA.
Effects of Overexposure:HLTH HAZS: AND OTHER BLOOD CELL ABNORMALITIES.
MAY CAUSE REPRODUCTIVE AND FETAL EFFECTS. NOTE: ETHYLENE GLYCOL
MONOMETHYL ETHER APPEARS ON THE NAVY LIST OF OCCUPATIONAL CHEMICAL
REPRODUCTIVE HAZARDS. SEEK CONSULTATION FROM APPROPRIATE HEALTH
PROFESSIONALS CONCERNING LATEST HAZARD LIST INFORMATION AND SAFE
HANDLING AND EXPOSURE INFORMATION . TARGET ORGANS: BLOOD, KIDNEYS,
CENTRAL NERVOUS SYST EM, LIVER, BONE MARROW, REPRODUCTIVE SYSTEM.
======================= First Aid Measures =======================
First Aid:EYES:IMMED FLUSH W/PLENTY OF WATER FOR AT LST 15 MINS, OCCAS
LIFTING UPPER & LOWER LIDS. GET MED AID. SKIN:GET MED AID IMMED.
IMMED FLUSH W/PLENTY OF SOAP & WATER FOR AT LST 15 MINS WHILE
REMOVING CON TAM CLTHG & SHOES. INGEST:IF VICTIM IS CONSCIOUS &
ALERT, GIVE 2-4 CUPFULS OF MILK/WATER. NEVER GIVE ANYTHING BY MOUTH
TO UNCONSCIOUS PERS. GET MED AID IMMED. INDUCE VOMIT BY GIVING 1
TSP OF SYRUP OF IPECAC. INHAL:REMOVE FROM EXPOS TO FRESH AIR
IMMED. IF NOT BRTHG, GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE OXYG.
GET MED AID. NOTES TO MD:TREAT SYMPTOMATICALLY & SUPPORTIVELY.
ANTIDOTE:NO SPECIFIC ANTI DOTE EXISTS.
===================== Fire Fighting Measures =====================
Flash Point:=41.7C, 107.F
Autoignition Temp:=285.C, 545.F
Lower Limits:1.8%
Upper Limits:14%
Extinguishing Media:FOR SMALL FIRES, USE WATER SPRAY, DRY CHEMICAL,
CARBON DIOXIDE OR CHEMICAL FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO COOL FIRE-EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:WARNING! FLAMMABLE LIQUID. VAPORS MAY
FORM AN EXPLOSIVE MIXTURE WITH AIR. VAPORS CAN TRAVEL TO A SOURCE
OF IGNITION AND FLASH BACK. NFPA RATING: HEALTH - 2; FLAMMABILITY -
2; REACTIVITY - 0.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR A NIOSH APPROVED SELF CONTAINED BREATHING
APPARATUS AND APPROPRIATE PERSONAL PROTECTION. USE PROPER PERSONAL
PROTECTIVE EQUIPMENT AS INDICATED IN EXPOSURE CONTROLS, PERSONAL
PROTECTION SECTION. A BSORB SPILL WITH INERT MATERIAL (E.G., DRY
SAND OR EARTH), THEN PLACE INTO A CHEMICAL WASTE CONTAINER. REMOVE
ALL SOURCES OF IGNITION.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM SOURCES OF IGNIT. DO
NOT STORE IN DIRECT SUNLIGHT. STORE IN TIGHTLY CLSD CNTNR. STORE IN
COOL, DRY, WELL-VENTED AREA AWAY FROM INCOMPAT SUBSTANCES. DO NOT
EXPOSE TO AIR. DO NOT GET ON S KIN OR IN EYES. DO NOT INGEST OR
INHALE. AVOID EXPOSURE - OBTAIN SPECIAL INSTRUCTIONS BEFORE USE.
Other Precautions:USE W/ADEQ VENT. GROUND & BOND CNTNRS WHEN
TRANSFERRING MATL. USE SPK-PROOF TOOLS & EXPLO PROOF EQUIP. EMPTY
CNTNRS RETAIN PROD RESIDUE, (LIQ &/OR VAP), & CAN BE DANGEROUS.
KEEP CNTNR TIGHTLY CLSD. DO NOT PRESSURIZE, CUT, WELD, BRAZE,
SOLDER, DRILL, GRIND/EXPOSE EMPTY CNTNRS TO HEAT, SPKS/OPEN FLAME
S. IN CASE (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
29 CFR 1910.134 OR EUROPEAN STANDARD EN 149. ALWAYS USE A NIOSH OR
EUROPEAN STANDARD EN 149 APPROVED RESPIRATOR WHEN NECESSARY.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
AIRBORNE CONCENTRATIONS BELOW THE PERMISSIBLE EXPOSURE LIMITS.
FACESHIELD .
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
Supplemental Safety and Health
OTHER PREC:OF ACCIDENT/IF YOU FEEL UNWELL, SEEK MED ADVICE IMMED (SHOW
LBL WHERE POSS). -- PHYSICAL & CHEM PROPERTIES: MOLECULAR FORMULA:
C3H8O2. MOLECULAR WT: N/P. -- OTHER INFO:OEL-AUSTRALIA, UNITED
KINGDOM:TWA 5 PPM (16 MG/M3); SKIN OEL-BELGIUM, DENMARK, FRANCE,
JAPAN, THE NETHERLANDS:TWA 5 PPM (ECOLOGICAL INFO)
================== Physical/Chemical Properties ==================
Boiling Pt:=124.2C, 255.6F
Melt/Freeze Pt:=-85.C, -121.F
Decomp Temp:Decomp Text:NOT AVAILABLE
Vapor Pres:9.7 MM HG @ 25C
Vapor Density:2.6(AIR=1)
Spec Gravity:0.966 @ 20C
pH:NOT AVAILABLE
Viscosity:NOT AVAILABLE
Solubility in Water:MISCIBLE
Appearance and Odor:COLORLESS LIQUID; PLEASANT ODOR - WEAK ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS AND ALKALIES. SUBSTANCE CAN REACT WITH AIR TO FORM
EXPLOSIVE PEROXIDES.
Stability Condition to Avoid:STABLE UNDER NORMAL TEMPERATURES AND
PRESSURES. AVOID INCOMPATIBLE MATERIALS, IGNITION SOURCES, EXCESS
HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
Conditions to Avoid Polymerization:HAS NOT BEEN REPORTED.
=================== Toxicological Information===================
Toxicological Information:CAS # 109-86-4: RTECS # KL5775000: LD50/LC50:
LC50:(INHAL,MOUSE) 1480 PPM/7H; LC50:(INHAL,RAT) 1500 PPM/7H;
LD50:(ORAL,MOUSE) 2560 MG/KG; LD50:(ORAL,RABBIT) 890 MG/KG;
LD50:(SKIN,RABBIT) 1280 MG/KG. E PIDEMIOLOGY:NO INFO AVAIL.
TERATOGENICITY:EFTS ON NEWBORN:BEHAVIORAL, INHAL-RAT TCLO=25
PPM/7H; BIOCHEM & METABOLIC, ORAL-RAT TDLO=175 MG/KG; GROWTH
STATISTICS, INHAL-RAT TCLO=100 PPM/6H. EMBRYO/FETUS :DEATH,
ORAL-MONKEY TDLO=930 MG/KG; FETOTOXICITY, ORAL-RAT TDLO=350 MG/KG.
SPECIFIC DEVEL ABNORMS: CARDIOVASCULAR, ORAL-RAT TDLO=175 MG/KG;
CNS & UROGENITAL, INTRAPERITONEAL(IPR)-RAT TDLO=190 MG/KG; M
USCULOSKELETAL, (ECOLOGICAL INFO)
===================== Ecological Information =====================
Ecological:ECOTOXICITY:NO INFO AVAIL. ENVIRON FATE:NO INFO REPORTED.
PHYSICAL/CHEM:NO INFO AVAIL. OTHER:NONE. -- TOX INFO:IPR-RAT
TDLO=330 MG/KG. REPRO EFTS:FERTILITY:ABORTION, ORAL-MONKEY TDLO=930
MG/KG; FEMALE INDEX, INHAL-RAT TCLO=100 PPM/6H; LITTER SIZE,
INHAL-MOUSE TCLO=50 PPM/6H. PATERNAL EFTS:SPERMATOGENESIS, ORAL-RAT
TDLO=250 M/KG; TESTES/SPERM DUCT/EPIDIDYMIS, ORAL-RAT TDLO=100
MG/KG. NEUROTOXICITY/ MUTAGENICITY:NO INFO AVAIL. OTHER
STUDIES:PLEASE REFER TO RTECS KL5775000 FOR ADDNL INFO. -- SUPP
DATA:(16 MG/M3); SKIN OEL-FINLAND:TWA 25 PPM (80 MG/M3); STEL 40
PPM (12 MG/M3); SKIN OEL-GERMANY:TWA 5 PPM (15 MG/M3); (TRANSPORT
INFO)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE AND LOCAL REGULATIONS. RCRA: D-SERIES MAXIMUM CONCENTRATION
OF CONTAMANTS; D-SERIES CHRONIC TOXICITY REFERENCE LEVELS;
F-SERIES; P-SERIES; & U-SER IES: NONE LISTED.
=================== MSDS Transport Information ===================
Transport Information:U.S. DOT:SHIPPING NAME:ETHYLENE GLYCOL MONOMETHYL
ETHER; HAZ CLASS:3; UN #:UN1188; PACKING GRP:III. IATA;
RID/ADR/IMO:SHIPPING NAME:NO INFO AVAIL. CANADA TDG:SHIPPING
NAME:ETHYLENE GLYCOL MONOMETHYL E THER; HAZ CLASS:3; UN #:UN1188;
PACKINGGRP:III; ADDNL INFO:FL PT:39C (102.2F). -- ECOLOGICAL
INFO:SKIN OEL-HUNGARY:TWA 15 MG/M3; STEL 30 MG/M3; SKIN OEL-THE
PHILIPPINES, TURKEY:TWA 25 PPM (80 MG/M3);SKIN OEL-POLAND:TWA 50
MG/M3; OEL-RUSSIA:TWA 5 PPM; OEL-SWEDEN:TWA 5 PPM (16 MG/M3); STEL
10 PPM (30 MG/M3); SKIN OEL-SWITZERLAND:TWA 5 PPM (15 MG/M3); STEL
10 PPM (30 MG/M3; SKIN JAN 9 OEL IN BULGARI A, COLOMBIA, JORDAN,
(SARA TITLE III)
===================== Regulatory Information =====================
SARA Title III Information:SECTION 302 (RQ):NONE OF CHEMS IN THIS MATL
HAVE RQ. SECTION 302 (TPQ):NONE OF CHEMS IN THIS PROD HAVE TPQ.
SARA CODES: CAS # 109-86-4:ACUTE, CHRONIC, FLAMM. SECTION 313:THIS
MATL CONTAINS 2-METHOXYET HANOL (CAS # 109-86-4, 98%), WHICH IS
SUBJECT TO REPORTING REQUIREMENTS OF SECTION 313 OF SARA TITLE III
& 40 CFR PART 373. -- TRANSPORT INFO:KOREA, NEW ZEALAND, SINGAPORE,
VIETNAM: CHECK ACGIH TLV.
Federal Regulatory Information:TSCA:CAS # 109-86-4 IS LISTED ON TSCA
INVENTORY. HLTH & SFTY REPORTING LIST:NONE OF CHEMS ARE ON HLTH &
SFTY REPORTING LIST. CHEM TEST RULES:NONE OF CHEMS IN THIS PROD ARE
UNDER CHEM TEST RULE. SECTIO N 12B:NONE OF CHEMS ARE LISTED UNDER
TSCA SECTION 12B. TSCA SIGNIFICANT NEW USE RULE:NONE OF CHEMS IN
THIS MATL HAVE SNUR UNDER TSCA. CLEAN AIR ACT:THIS MATL DOES NOT
CONTAIN ANY HAZ AIR POLLUTANTS; C LASS 1/CLASS 2 OZONE DEPLETORS.
CLEAN WATER ACT:NONE OF CHEMS IN THIS PROD ARE LISTED AS HAZ
SUBSTAN CES; PRIORITY/TOX POLLUTANTS UNDER CWA. OSHA:NONE OF CHEMS
IN THIS PROD ARE CONSIDERED HIGHLY HAZ BY OSHA. EUROPEAN/ (STATE
REGULATORY INFO)
State Regulatory Information:CAS # 109-86-4 CAN BE FOUND ON FOLLOWING
STATE RIGHT TO KNOW LISTS: CALIFORNIA, NEW JERSEY, FLORIDA,
PENNSYLVANIA, MINNESOTA, MASSACHUSETTS. FOLLOWING STATEMENT(S)
IS(ARE) MAKE IN ORDER TO COMPLY W/CA LIFORNIA SAFE DRINKING WATER
ACT: WARNING:THIS PROD CONTAINS 2-METHOXYETHANOL, CHEM KNOWN TO
STATE OF CALIFORNIA TO CAUSE BIRTH DEFECTS/OTHER REPRO HARM.
CALIFORNIA NO SIGNIFICANT RISK LEVEL:NONE OF C HEMS IN THIS PROD
ARE LISTED. -- FED REGULATORY:INTERNATIONAL REGS:EUROPEAN LABELING
I/A/W EC DIRECT IVES:HAZ SYMBOLS: T F. RISK PHRASES: R 10 - FLAMM.
R 20/21/22 - HARMFUL BY INHAL, IN CONT W/SKIN & IF SWALLOWED. R 60
- MAY (OTHER INFO)
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:F-1000 SENTRY SEAL
CAGE:01195
CAGE:01195
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 60%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METALLIC DRIERS
Fraction by Wt: .1-.4%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:FATIGUE, HEADACHE, MENTAL CONFUSION,
STRONG DEGREASER OF SKIN. EYE: SEVERE IRRITATION, UNCONSCIOUSNESS,
NAUSEA. IF SWALLOWED, VOMITING.
Effects of Overexposure:FATIGUE, HEADACHE, MENTAL CONFUSION, STRONG
DEGREASER OF SKIN. EYE: SEVERE IRRITATION, UNCONSCIOUSNESS, NAUSEA.
IF SWALLOWED, VOMITING.
======================= First Aid Measures =======================
First Aid:REMOVE TO FRESH AIR. WASH AND FLUSH AFFECTED AREAS WITH WATER
AND SOAP, FLUSH EYES. DO NOT INDUCE VOMITING IF SWALLOWED, KEEP
WARM AND QUIET. CALL FOR MEDICAL HELP.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:45.0F,7.2C
Extinguishing Media:CARBON DIOXIDE OR DRY CHEMICAL, REGULAR FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS WITH A
FULL FACE PIECE WITH PRESSURE ON DEMAND.
Unusual Fire/Explosion Hazard:KEEP AWAY FROM PILOT LIGHTS, LIGHTS,
FLAMES, SPARKS, HEATERS, SMOKERS.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. WEAR SUITABLE
PROTECTIVE EQUIPMENT. COLLECT IN A FLAMMABLE WASTE CONTAINER FOR
DISPOSAL.
======================Handling and Storage ======================
EQUIPMENT TO PREVENT PROLONGED SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AIR SUPPLIED MASKS IN CONFINED AREAS, IF LARGE
QUANTITIES USED.
Ventilation:LOCAL EXHAUST: PERFERRED. MECHANICAL (GENERAL): ACCEPTABLE
Other Protective Equipment:SAFETY SHOWER AND EYE BATH.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:230F,110C
Vapor Pres:20
Vapor Density:3.2
Spec Gravity:.87
Evaporation Rate & Reference:2.4
Solubility in Water:NIL
Appearance and Odor:AROMATIC ODOR, HEAVY THICK PASTE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:AVOID HEAT, SPARKS, AND FIRES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DESTROY BY LIQUID INCINERATION. USE ABSORBENT
MATERIAL AND DEPOSIT IN TOXIC LANDFILL IN ACCORDANCE WITH LOCAL,
STATE, AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MD-A
CAGE:1DJ45
CAGE:1DJ45
============= Composition/Information on Ingredients =============
Ingred Name:DICHLORODIFLUOROMETHANE (SARA III)
CAS:75-71-8
RTECS #:PA8200000
Other REC Limits:NONE SPECIFIED
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION; VAPOR IS HEAVOR THAN AIR
AND CAN CAUSE SUFFOCIATION BY REDUCING OXYGEN AVAILABILITY.
BREATHING HIGH CONCENTRATIONS MAY CAUSE LIGHTHEADNESS, SHORTNESS OF
BREATH AND MAY LEAD TO UNCONCIOUSNE SS.
Effects of Overexposure:NA
Medical Cond Aggravated by Exposure:NA
======================= First Aid Measures =======================
First Aid:REMOVE PERSON TO FRESH AIR.REMOVE IGNITION SOURCES
===================== Fire Fighting Measures =====================
Flash Point:NA
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:NA
Fire Fighting Procedures:NA
Unusual Fire/Explosion Hazard:MAY DECOMPOSE,HEATED CANS MAY EXPLODE
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA ESPICALLY LOW PLACES WHERE
VAPORS MAY COLLECT.REMOVE SOURCES OF IGNITION
Neutralizing Agent:NA
======================Handling and Storage ======================
Handling and Storage Precautions:USE AIR MASK IN HIGH CONCENTRATION
AREAS,AVOID STORAGE ABOVE 80F AVOID DIRECT SPRAY CONTACT SINCE IT
MAY CAUSE FROSTBITE
Other Precautions:NA
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR LARGE SPILLS
Ventilation:RECOMMENDED
Other Protective Equipment:NA
Work Hygienic Practices:PRUDENT
Supplemental Safety and Health
NA
================== Physical/Chemical Properties ==================
HCC:G3
Boiling Pt:B.P. Text:-21F,-29C
Melt/Freeze Pt:M.P/F.P Text:100F,38C
Vapor Pres:84.9
Vapor Density:4.32
Spec Gravity:1.325
Evaporation Rate & Reference:RAPID
Solubility in Water:NEGIBLE
Appearance and Odor:INVISIBLE GAS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKAI OR ALKALINE EARTH METALS-POWERED AL,ZINC,BERYLLIUM ETC.
Stability Condition to Avoid:OPEN FLAMES OR HIGH TEMPERATURES.
Hazardous Decomposition Products:HYDROCHLORIC AND HYDROFLUORIC ACIDS-
POSSIBLE PHOSGENE
==================== Disposal Considerations ====================
Waste Disposal Methods:EVAPORATE OUTDOORS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ENAMEL ALKYD S.G. GRAY 26173 ID745016
Preparer's Name:W.A. ELLISON
CAGE:FO127
CAGE:FO127
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:MINERAL SPIRITS
(VAPOR PRESSURE 2 MM HG @ 20C)
CAS:8032-32-4
OSHA PEL:500 PPM 2950 MG/CU.M
ACGIH TLV:100 PPM 525 MG/CU.M.
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE
CAS:14464-46-1
RTECS #:VV7325000
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.05 MG/M3 RDUST9293
Ingred Name:TALC (CONTAINING NO ASBESTOS)
CAS:14807-96-6
RTECS #:WW2710000
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST; 9192
Ingred Name:BARIUM COMPOUNDS
CAS:7440-39-3
OSHA PEL:.5000 MG/CU.M.
ACGIH TLV:.5000 MG/CU.M.
Ingred Name:IRON OXIDE
CAS:1309-37-1
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
Ingred Name:VOC. ORGANIC CMPD 3.7 LB/GAL LESS WATER & NPRS* 444 G/L
LESS WATER VOC. 8.6 LB/GAL SOLIDS 1032 G/L SOLIDS CALCU
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED/REPEATED EXP TO CRYSTALLINE
SILICA-PNEUMOCONIOSIS, PROGRESSIVE DISABLELUNG DISEASE. MAY CAUSE
PERMANENT BRAIN & NERVOUS SYS DAM. INTENTIONAL MISUSE
BYDELIBERATELY CONCENTRATING AND INHALING THE CONTENTS MAY BE
HARMFUL OR FATAL.
Explanation of Carcinogenicity:MANUFACTURER CONCLUDES THAT THERE IS NO
SIGNIFICANT HAZARDFOR MAN.
Effects of Overexposure:SWALLOW: GASTROINTESTINAL IRRI, NAUSEA, VOMIT,
ASPIRATION INTO LUNG, CHEM PNEUMONITITS, CAN BE FATAL. INHAL:
NOSE/THROAT IRRI. HIGH CONCENT CAUSE ACUTE CENT NERV SYS DEPRESSION
CHAR HEADACHE, DIZZ, NA USEA & CONFUSION. EYE: IRRI. SKIN: DEFATTNG
AND IRRITATION OF THE SKIN. INHAL: ANESTHETIC, EVEN ASPHYXIATION
======================= First Aid Measures =======================
First Aid:SWALLOW: DO NOT INDUCE VOMIT. CALL POISON CONTROL
CENTER/HOSPITAL EMERG ROOM/PHYSICIAN IMMED. INHAL: REMOVE TO FRESH
AIR IMMED. BREATH HAS STOPPED, GIVE CPR. KEEP WARM, QUIET. GET MED
ATTN IMMED. EYE: FLUSH W/LARGE AMTS OF WATER, LIFTING LIDS OCCAS,
FOR AT LEAST 15 MIN. GET MED ATTN. SKIN: REMOVE CONTAM CLOTHES.
WASH AFFECT AREA W/SOAP & WTR. OBTAIN MED ATTN. IRRI PERSISTS.
===================== Fire Fighting Measures =====================
Flash Point:80 F/26.67 C
Extinguishing Media:NFPA CL B FIRE EXTING (CARBON DIOXIDE,ALL PUR DRY
CHEM OR ALCOHOL FOAM) FOR EXTING FLAMM LIQ FIRES. POLYMER FOAM
PERFER
Fire Fighting Procedures:WEAR SCBA. WATER MAY BE INEFFECTIVE, USED TO
COOL TO PREVENT PRESSURE BUILD UP AUTO-IGNITE/EXPLOSION FROM HEAT.
IF WATER IS USED FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT,ELEC EQUIP,SPARKS, ETC. CLOSED CONTAINERS MAY
EXPLODE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. DIKE &
CONTAIN SPILL W/INERT MATERIAL. TRANSFER LIQUID TO COVER METAL
CONTAIN FOR RECOVERY/DISPOSAL. USE NON SPARKING TOOLS. PREVENT
CONTAMINATION OF SEWERS,STREAMS & GROUNDWATER WITH SPILLED MATERIAL
OR USED ABSORB
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 95F. STORE LARGE
QUANTITIES IN COMPLIANCE W/OSHA 29CFR1910.106. CLOSE CONTAINER
AFTER EACH USE. DO NOT TAKE INTERNALLY.
Other Precautions:KEEP AWAY FROM CHILDREN. DO NOT BREATHE SANDING DUST.
WASH HANDS & FACE THOROUGHLY BEFORE EATING OR DRINKING. EMPTY CONT
MUST NOT BE WASHED & RE-USED FOR ANY PURPOSE. CONT SHOULD BE
GROUDED/BONDED TO RECEIVING CONT. DO NOT WELD, BRAZE, ETC.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:GENERAL EXPOSURE TO ORGANIC CHEM MAY NOT REQUIRE
THE USE OF RESPIR PROTECTION IFWELL VENT AREA. RESTRICTED VENT:
NIOSH APPROVED CHEM CARTRIDGE RESPIR MAY BE REQUIRED. UNDER
SPRAYING: MECH PREFILTER. C ONFINED AREA: AIR SUPPLIED RESPIRATOR
Ventilation:GEN DILUTION/LOCAL EXHAUST VENT SUFFICIENT VOL/PATTERN KEEP
CONCEN HAZARD INGRED BELOW THE LOWEST EXPOSURE LIMIT
Other Protective Equipment:AS REQUIRED TO PREVENT SKIN CONTACT
Work Hygienic Practices:WASH HANDS AND FACE THOROUGHLY BEFORE EATING OR
DRINKING.
Supplemental Safety and Health
THIS PRODUCT, IF DISCARDED DIRECTLY, WOULD BE CLASSIFIED A HAZARDOUS
WASTE BASEDON ITS IGNITABILITY CHAR. THIS PRODUCT CONTAINS LEAD,
WHICH, IF PRESENT IN WASTEAT 5.0 MG/1 OR MORE AFTER BEING EXTRACTE
D, IS CONSIDERED EP TOXIC, AND THEREFOREA HAZARDOUS WASTE UNDER
RCRA REGULATIONS. HAZARD WASTE NO. DOO8
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:148-395 F
Vapor Density:> AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:56
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID EXCESSIVE HEAT & SOURCES OF IGNITION. STRONG ACIDS OR ALKALINE
MATERIALS
Hazardous Decomposition Products:BURNING, INCLUDE WHEN HEATED BY
WELD/CUTTING, WILL PRODUCESMOKE, CARBON MONOXIDE/CARBON DIOXIDE.
OXIDES OF LEAD-GENERA
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL,STATE, &
LOCAL REGULATION. INCINERATE ONLY IN EPA PERMITTED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS. CONTAMINATED ABSORBENT DISPOSE IN
HAZARDOUS WASTE LANDFILL
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ZINC SULFATE, 7-HYDRATE, 4382
CAGE:DO803
CAGE:DO803
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:ZINC SULFATE HEPTAHYDRATE (1:1:7); (ZINC SULFATE,
7-HYDRATE)
CAS:7446-20-0
RTECS #:ZH5300000
Fraction by Wt: 99-100%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:SKIN/EYE CONTACT:IRRITATION.
INGEST:GASTROINTESTINAL PAIN. CHRONIC:NONE IDENTIFIED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE IDENTIFIED.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD. IF SWALLOWED, IF CONSCIOUS, IMMEDIATELY
INDUCE VOMITING. INHAL:REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTF RESP. IF BREATHING IS DIFFICULT, GIVE OXYGEN. SKIN:FLUSH
W/WATER. EYES:I MMEDIATELY FLUSH W/PLENTY OF WATER FOR AT LEAST 15
MINUTES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE IDENTIFIED.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT CLTHG.
WITH CLEAN SHOVEL, CAREFULLY PLACE MATL INTO CLEAN, DRY CONTAINER &
COVER; REMOVE FROM AREA. FLUSH SPILL AREA W/WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED.
SUITABLE FOR ANY GENERAL CHEMICAL STORAGE AREA.
Other Precautions:CAUSES IRRITATION. HARMFUL IF SWALLOWED. AVOID
CONTACT W/EYES, SKIN, CLOTHING. DO NOT BREATHE DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCENTRATION IS HIGH, USE AN
APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR OR DUST MASK.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
FUME OR DUST LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:LAB COAT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:212F,100C
Spec Gravity:1.97 (H*2O=1)
Solubility in Water:APPRECIABLE (>10%)
Appearance and Odor:SOLID, COLORLESS CRYSTALLINE POWDER; ODORLESS.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER.
Stability Condition to Avoid:HEAT, MOISTURE.
Hazardous Decomposition Products:OXIDES OF SULFUR, OXIDES OF ZINC.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W ALL APPLICABLE FEDERAL, STATE &
LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RC65 FLOURESCENT PENETRANT
CAGE:21405
CAGE:21405
============= Composition/Information on Ingredients =============
Ingred Name:ALIPHATIC OIL REFINED, HYDROTREATED MIDDLE DISTILLATE
Fraction by Wt: 50-70%
Other REC Limits:NONE SPECIFIED
Ingred Name:PHOSPHATE ESTER
Fraction by Wt: 15-25%
Other REC Limits:NONE SPECIFIED
Ingred Name:PHTHALATE ESTER
Fraction by Wt: 15-25%
Other REC Limits:NONE SPECIFIED
Ingred Name:FLUORESCENT DYE
Fraction by Wt: 1-7%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:RESPIRATORY TRACT IRRITATION. CENTRAL
NERVOUS SYSTEM STIMULATION, FOLLOWED BY DEPRESSION IN VARYING
DEGREES.
Explanation of Carcinogenicity:THE COMPONENTS OF THIS PRODUCT HAVE NOT
SHOWN ANY EVIDENCE OF BEING CARCINOGENIC.
Effects of Overexposure:OVEREXPOSURE MAY LEAD TO RESPIRATORY
IRRITATION, NAUSEA, FATIGUE, DIZZINESS, HEADACHES, DERMATITIS AND
EYE IRRITATION.
Medical Cond Aggravated by Exposure:PERSONS WITH A SKIN DISORDER SHOULD
USE CAUTION WHEN HANDLING OR USING THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:SKIN: REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER.
GET MEDICAL ATTENTION IF IRRITATION PERSISTS. INHALATION: REMOVE TO
FRESH AIR & RESTORE BREATHING IF NECESSARY. GET MEDICAL ATTENTION.
EYE : IMMEDIATELY FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING
EYELIDS OPEN. GET MEDICAL ATTENTION. INGESTION: GET IMMEDIATE
MEDICAL ATTENTION. DO NOT INDUCE VOMITING. PREVENT ASPIRATION INTO
LUNGS.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>200F,>93C
Autoignition Temp:Autoignition Temp Text:UNKNON
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS. DO NOT USE DIRECT
STREAM OF WATER WHICH CAN SPREAD THE FIRE. PRODUCT MAY FLOAT.
================== Accidental Release Measures ==================
Spill Release Procedures:MINOR: ABSORB MATERIAL WITH CLAY, VERMICULITE,
OR SIMILAR ABSORBENT MATERIAL. PLACE IN DISPOSAL CONTAINERS. MAJOR:
DIKE & CONTAIN SPILL. ELIMINATE SOURCES OF IGNITION. SHUT OFF
LEAKS. REMOVE LIQUID BY VACUUM OR ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, AREA AWAY FROM
SOURCES OF IGNITION. KEEP CONTAINERS CLOSED WHEN NOT IN USE. EMPTY
CONTAINERS CAN CONTAIN HAZARDOUS LIQUID/VAPOR.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VAPORS AND MISTS ARE GENERATED, USE
NIOSH/MSHA APPROVED RESPIRATOR TO PREVENT OVEREXPOSURE. CONSULT
RESPIRATOR MANUFACTURER TO DETERMINE APPROPRIATE TYPE EQUIPMENT FOR
GIVEN APPLICATION.
Ventilation:LOCAL EXHAUST RECOMMENDED. AVOID OPEN ELECTRICAL SOURCES
NEAR PRODUCT VAPOR AREAS.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER.
Work Hygienic Practices:DO NOT TAKE INTERNALLY. AVOID SKIN CONTACT.
WASH SKIN AFTER USING PRODUCT. DO NOT EAT, DRINK OR SMOKE IN WORK
AREA.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:460F,238C
Evaporation Rate & Reference:<0.1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:YELLOW GREEN LIQUID, PETROLEUM ODOR
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:OPEN FLAMES AND MATERIALS AND HAZARDS
NORMALLY INCOMPATIBLE WITH PETROLEUM OILS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
OTHER HYDROCARBON COMPOUNDS DURING COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MAY BE BURNED IN AN APPROVED INCINERATOR
OR DISPOSED OF IN ACCORDANCE WITH ALL APPLICABLE LOCAL, STATE AND
FEDERAL LAWS AND REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SODIUM HYPOCHLORITE SOL.
CAGE:60777
CAGE:60777
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYPOCHLORITE
RTECS #:WB5800500
Fraction by Wt: 15%
Ingred Name:SODIUM CHLORIDE
CAS:7647-14-5
RTECS #:VZ4725000
Fraction by Wt: 13.5%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 71.5%
======================= First Aid Measures =======================
First Aid:IF SWALLOWED- GIVE SEVERAL GLASSES OF MILK OR WATER,FOLLOWED
BY OIL OR COOKING OIL;SKIN/EYES:IF SPLASHED IN OR ON,FLOOD WITH
WATER,CALL A DOCTOR IMMEDIATELY.
================== Accidental Release Measures ==================
Spill Release Procedures:DILUTE WITH COPIOUS AMTS. OF WATER.OR IF NOT
AVAILABLE, ABSORB ON INERT MATERIALS SUCH AS PARTICULATE CLAY OR
DIATOMACEOUS EARTH; SO NOT BRING ADSORBED WASTE INTO CONTACT WITH
OXODIZABLE MATERIALS
======================Handling and Storage ======================
Handling and Storage Precautions:DONOT CONTAMINATE WITH OXIDIZABLE
MATERIAL.STORE IN COOL PLACE OUT OF SUNLIGHT.
Other Precautions:KEEP OUT OF CHILDREN S REACH.HARMFUL IF
SWALLOWED.SKIN & EYE CONTACT MAY CAUSE SEVERE IRRITATION.
============= Exposure Controls/Personal Protection =============
Other Protective Equipment:RUBBER APRON & BOOTS
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:B1
Boiling Pt:=93.3C, 200.F
Spec Gravity:1.26
Evaporation Rate & Reference:(H*2O = 1) = 1
Appearance and Odor:LIGHT YELLOW COLOR,SLIGHT CHLORINE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
AVOID MIXING WITH ACIDS
Stability Condition to Avoid:AVOID SUNLIGHT & TEMPERATURES OVER 90 F.
OXYGEN EVOLVES
Hazardous Decomposition Products:EMITS CHLORINE ON CONTACT WITH ACID.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN POLYETHYLENE OR ALUMINUM
CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PR-1574 BLACK, PART A
Kit Part:Y
CAGE:DO563
CAGE:83574
CAGE:DO563
============= Composition/Information on Ingredients =============
Ingred Name:N,N BIS-(2-HYDROXYPROPYL)-ANILINE
CAS:3077-13-2
Fraction by Wt: 35%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES-IRRITATION. SKIN-LOCAL
IRRITATION. INGEST-NONE KNOWN.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:INHALE-MAY CAUSE HEADACHE, DIZZINESS,
NERVOUSNESS, INCREASED PULSE RATE, HYPETENSION AND VASODILATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LUKE WARM WATER FOR 15 MINUTES, CONSULT
PHYSICIAN. SKIN: WASH WITH SOAP AND WATER. IF SYMPTOMS PERSISTS,
CONSULT A PHYSICIAN. INHALATION: REMOVE TO FRESH AIR. IF SYMPTOMS
ARE PRESENT CONSULT A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:USE AIR SUPPLIED RESPIRATOR.
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP INTO CONTAINER. CLEAN-UP RESIDUE WITH
1,1,1-TRICHLORETHANE.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:GENERAL VENTILATION TO MAINTAIN VAPOR BELOW PEL.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING, DRINKING OR SMOKING.
Supplemental Safety and Health
ITEM IS A TWO PART KIT.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.02
Solubility in Water:NEGLIGIBLE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OXIDES OF CARBON AND NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:NOT A HAZARDOUS WASTE ACCORDING TO EPA
REGULATIONS. CONSULT STATE REGULATIONS PRIOR TO DISPOSAL OF
SPILLAGE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:INJEX (AEROSOL)
Preparer's Name:LOUISE MOORE
CAGE:06645
CAGE:06645
============= Composition/Information on Ingredients =============
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
CAS:1330-20-7
RTECS #:ZE2100000
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE; DIMETHYL KETONE
CAS:67-64-1
RTECS #:AL3150000
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:DICHLOROMETHANE (METHYLENE CHLORIDE) (SUSPECTED HUMAN
CARCINOGEN BY ACGIH, NTP)
CAS:75-09-2
RTECS #:PA8050000
OSHA PEL:500 PPM
ACGIH TLV:174 MG/CUM (A2)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INGESTION: HARMFUL OR FATAL.
EYES/SKIN: IRRITATION.
Explanation of Carcinogenicity:SEE INGREDIENTS
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINUTES. SKIN: WASH W/SOAP &
WATER. INGESTION: DON'T INDUCE VOMITING. GIVE A GLASS OF WATER.
DON'T GIVE LARGE AMOUNTS OF WATER AS THIS MAY CAUSE VOMITING.
OBTAIN MEDICAL ATT ENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, DRY CHEMICAL, CO2
Fire Fighting Procedures:KEEP EXPOSED CANS COOL BY SPRAYING W/COOL
WATER.
Unusual Fire/Explosion Hazard:FLAMMABLE
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. REFER TO FEDERAL,
STATE & LOCAL REGULATIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE INDOORS OUT OF SUN RAYS & AT
TEMPERATURES BELOW 120F. KEEP PRODUCT STORED AWAY FROM HEAT & OPEN
FLAMES.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. CONTENTS UNDER
PRESSURE. STORAGE NEAR FLAMES OR HEAT CAN CAUSE CANS TO RUPTURE OR
BURST. AVOID BREATHING VAPORS.
============= Exposure Controls/Personal Protection =============
Ventilation:LOCAL EHXAUST
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Density:2
Spec Gravity:0.892-0.90
Evaporation Rate & Reference:(ETHER=1): 1.8-85
Solubility in Water:PARTIAL
Appearance and Odor:CLEAR LIQUID; HYDROCARBON ODOR.
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:FLAMES OR HEAT
Hazardous Decomposition Products:HYDROGEN CHLORIDE & SMALL AMOUNTS OF
CHLORINE PHOSGENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:POLYETHYLENE, CHLORINATED, 186
CAGE:0MWG0
CAGE:0MWG0
============= Composition/Information on Ingredients =============
Ingred Name:POLYETHYLENE, CHLORINATED
CAS:64754-90-1
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MINOR IRRITATION MAY OCCUR UPON
CONTACT WITH EYES AND SKIN. NO OTHER HEALTH EFFECTS ARE KNOWN TO
EXIST.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:IN ALL CASES, IF IRRITATION DEVELOPS, SEEK MEDICAL
ASSISTANCE. INHAL: REMOVE FROM EXPOSURE. IF BREATHING STOPS, BEGIN
MOUTH TO MOUTH. EYES: FLUSH WITH WATER FOR AT LEAST 15 MIN. SKIN:
WASH AFFECTED AR EA WITH SOAP AND WATER. REMOVE DIRTY CLOTHING.
INGEST: CALL MD IMMED .
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER FOG, FOAM, ALCOHOL FOAM, DRY CHEMICAL, CO*2.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:HCL GAS EVOLVES AT HIGH TEMPERATURES.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP AND PLACE IN SUITABLE CONTAINER FOR
DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A DRY PLACE. KEEP CONTAINERS
CLOSED TO PVNT CONTAMINATION. OPEN CONTAINERS IN WELL-VENTILATED
AREA.
Other Precautions:THIS MATERIAL INTENDED FOR LAB USE ONLY. IT IS NOT
SOLD/INTENDED FOR DRUG, HOUSEHOLD OR OTHER USES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST ADEQUATE.
Other Protective Equipment:EMERG EYE WASH & DELUGE SHOWER WHICH MEETS
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:1.15
Solubility in Water:NIL
Appearance and Odor:OFF-WHITE CRUMBS; ODORLESS.
Percent Volatiles by Volume:0.2
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:AVOID HIGH TEMPERATURES - HCL GAS EVOLVED.
Hazardous Decomposition Products:HCL GAS
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL OR INCINERATE IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FORM-EZE
CAGE:55278
CAGE:55278
============= Composition/Information on Ingredients =============
Ingred Name:HEMATITE; (IRON OXIDE)
CAS:1317-60-8
RTECS #:MH7600000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICA GEL; (CERAMIC FIBER LOW CONCENTRATION OF SILICA
ALUMINA IN FORM OF QUARTZ)
CAS:112945-52-5
RTECS #:VV7310000
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:BENZOIC ACID, P-HYDROXY-, PROPYL ESTER; (PROPYLPARABEN)
CAS:94-13-3
RTECS #:DH2800000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BENZOIC ACID, P-HYDROXY-, METHYL ESTER; (METHYLPARABEN)
CAS:99-76-3
RTECS #:DH2450000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER; (DEIONIZED WATER)
CAS:7732-18-5
RTECS #:ZC0110000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:FUMES & GASES CAN BE DANGEROUS TO YOUR
HEALTH. ARC RAYS CAN INJURE EYES & BURN SKIN. ELECTRIC SHOCK CAN
KILL. SHORT-TERM OVEREXPOSURE TO WELDING FUMES MAY RESULT IN
DISCOMFORT SUCH AS DIZZINESS, NAUSE A OR DRYNESS OR IRRITATION OF
NOSE, THROAT OR EYES, TIGHTNESS IN CHEST, FEVER & ALLERGIC
REACTIONS. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: CHRONIC OVEREXPOSURE TO WELDING FUMES
MAY LEAD TO SIDEROSIS (IRON DEPOSIT IN LUNG) & IS BELIEVED BY SOME
INVESTIGATORS TO AFFECT PULMONARY FUNCTION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMED . INHAL: REMOVE TO FRESH AIR. SUPPORT
BRTHG (GIVE OXYGEN/ARTF RESP) . EYES: IMMED FLUSH W/POTABLE WATER
FOR A MINIMUM OF 15 MIN, SEEK ASSISTANCE FROM MD . SKIN: FLUSH
W/COPIOUS AMOUNTS OF WATER. CALLMD . BROKEN ENDS OF DRY FIBER MAY
CAUSE IRRIT & INFLAMM DUE TO MECH RXN TO SHARP ENDS OF FIBERS. WASH
AREA OF CNTCT W/SOAP & WATER. DO NOT RUB OR SCRATCH.
===================== Fire Fighting Measures =====================
Flash Point:NON-COMBUSTIBLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:WELDING ARC & SPARKS CAN IGNITE
COMBUSTIBLES & FLAMMS. REFER TO AMERICAN NATIONAL STANDARD Z49.1
FOR FIRE PREVENTION DURING USE OF WELDING & ALLIED PROCEDURES.
================== Accidental Release Measures ==================
Spill Release Procedures:SCRAPE UP AND WASH WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:READ & UNDERSTAND THE MANUFACTURER'S
INSTRUCTION AND THE PRECAUTIONARY LABEL ON THE PRODUCT.
Other Precautions:USE EXHAUST SYSTEM TO CLEAR WELDING FUMES. MAKE SURE
INHALED AIR DOES NOT CONTAIN FUME CONSTITUENTS ABOVE PERMISSIBLE
EXPOSURE LEVELS. TRAIN WELDER NOT TO TOUCH LIVE ELECTRICAL PARTS &
TO INSULATE HIM /HERSELF FROM WORK & GROUND.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRABLE FUME
RESPIRATOR OR AIR SUPPLIED RESPIRATOR WHEN WELDING IN CONFINED
SPACE OR WHERE LOCAL EXHAUST OR VENTILATION DOES NOT KEEP EXPOSURE
BELOW THE RECOMMENDED EXPOSURE LIMIT.
Ventilation:USE ENOUGH VENT, LOC EXHST AT ARC OR BOTH TO KEEP FUMES &
GASES FROM WORKER'S BRTHG ZONE & GENERAL AREA. TRAIN (SUPDAT)
Other Protective Equipment:PROT WHICH HELPS PVNT INJURY FROM RADIA,
SPK, ELEC SHOCK. MAY INCL ARM/SHOULDER PROT,APRON,HAT & DARK
SUBSTANTIAL CLTHG.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HAZ DECOMP PROD: REACTION PRODS MAY INCL CARBON MONOXIDE & CARBON
DIOXIDE, OZONE & NITROGEN OXIDES MAY BE FORMED FROM THE RADIATION
FROM THE ARC. VENT: WELDER TO KEEP HIS/HER HEAD OUT OF FUMES. EYE
PR OT: FILTER LENS SHOULD BE PROPER SHADE NUMBER. PROVIDE PROT
SCREEN & FLASH GOGGS IF NEC TO SHIELD OTHERS.
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:COMPOSITION & QUALITY ARE DEPENDENT
UPON METAL BEING WELDED, PROCESS, PROC, ELECTRODES & COATINGS USED.
GASEOUS (SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT RESIDUE, DISPOSABLE CONTAINER OR
LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER IN FULL COMPLIANCE
WITH FEDERAL, STATE & LO CAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-D-81298,DYE LIQUID YELLOW, TY 2
CAGE:60777
CAGE:60777
============= Composition/Information on Ingredients =============
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 70%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:NAPHTHA (PETROLEUM SPIRITS OR BENZIN)
CAS:8030-30-6
RTECS #:SE7555000
Fraction by Wt: 25%
OSHA PEL:100 PPM
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: TRACE
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:MATERIAL WILL STAIN SKIN.WILL IRRITATE
EYES.INHALED:COMA,ASPHYXIATION,INGEST:IRRITNT,VOMIT,DIARRHEA.
======================= First Aid Measures =======================
First Aid:SKIN:WASH W. SOAP & WATER.EYES:FLUSH WITH WATER 15
MIN.INHALED:REMOVE TO FRESH AIR.GIVE CPR/OXYGEN IF NEED.INGESTED:DO
NOT INDUCE VOMIT.GIVE SEVERAL OZ OF MINERAL OIL TO ABSORB MINERAL
SPIRITS.GET MED ICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:95F TCC
Lower Limits:UNK
Upper Limits:UNK
Extinguishing Media:WATER,CO*2
Fire Fighting Procedures:WEAR SELF-CNTND BRTHG APP.USE H*2O TO COOL
EXPOSED CONTAINER
Unusual Fire/Explosion Hazard:MAY BE IGNITED BY
HEAT,SPARKS,FLAME.CONTAINER MAY EXPLODE IN HEAT OF FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES.ABSORB WITH
SAND,EARTH,VERMICULITE,OTHER ABSORBING MATL.PLACE IN SEAL
CONTAINER.LG SPILL:DIKE FOR LATER DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID IGNITION SOURCES.PROTECT FROM
PHYSICAL DAMAGE.KEEP CONTAINER CLOSED.STORE IN A COOL DRY AREA.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPRVD CHEMICAL RESPIRATOR IN ENCLOSED
AREAS
Ventilation:MECHANICAL SUFFICIENT TO MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment:NONE
Supplemental Safety and Health
ITEM MEETS REQUIREMENTS FOR TYPE II UNDER MIL SPEC D-81298.
================== Physical/Chemical Properties ==================
HCC:F3
Appearance and Odor:YELLOW OILY LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:AVOID HIGH TEMPERATURES,IGNITION SOURCES.
Hazardous Decomposition Products:CO,CO*2,PARTIALLY BURNED HYDROCARBONS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN AN APPROVED COMMERCIAL CHEMICAL DUMP
SITE IN ACCORDANCE WITH LOCAL,STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DETERGENT, GENERAL PURPOSE
Preparer's Name:ERVIN SMITH
CAGE:61071
CAGE:61071
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM CARBONATE
CAS:497-19-8
RTECS #:VZ4050000
Fraction by Wt: 45.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM SILICATE
CAS:1344-09-8
Fraction by Wt: 10.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DODECYLBENZENESULFONIC (SOD-SALT)
CAS:26264-05-1
Fraction by Wt: 5.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM SULFATE
CAS:7757-82-6
RTECS #:WE1650000
Fraction by Wt: 40.0%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DUST MAY CAUSE SLIGHT COUGHING AND
IRRITATION.
======================= First Aid Measures =======================
First Aid:INHAL: GET FRESH AIR. CALL DR.
===================== Fire Fighting Measures =====================
Flash Point:NA
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:NA
Fire Fighting Procedures:NONE REQUIRED
Unusual Fire/Explosion Hazard:NA
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A NORMAL WAREHOUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE DUST RESPIRATOR
Ventilation:NORMAL
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NA
Decomp Temp:Decomp Text:NA
Vapor Pres:NA
Vapor Density:>AIR = 1
Spec Gravity:>2.0
pH:1.0
Viscosity:NA
Evaporation Rate & Reference:NA
Solubility in Water:COMPLETE
Appearance and Odor:WHITE POWDER
Percent Volatiles by Volume:100
Corrosion Rate:NA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
DONT MIX OR USE NEAR ACIDS.
Hazardous Decomposition Products:NA
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SP238
CAGE:JO774
CAGE:81831
CAGE:JO774
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMED.SKIN:WASH W/SOAP IMMED.INHAL:REMOVE
TO FRESH AIR.GIVE ART.RESPIR. AS NEEDED.INGEST:GET MEDICAL
ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE VOMITING,BUT DO NOT MAKE
UNCONSCIOUS PE RSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS.CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE,THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW COLORED LIQUID,AROMATIC ODOR.
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PRECIPATH U UNIVERSAL CONTROL SERUM FOR THE
CAGE:32239
CAGE:32239
============= Composition/Information on Ingredients =============
Ingred Name:THE MANUFACTURER STATES THAT NO HAZARDOUS INGREDIENTS ARE
PRESENT IN THIS PRODUCT.
RTECS #:9999999ZZ
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS PRODUCT IS A LYOPHILIZED CONTROL
SERUM. IT IS BASED ON HUMAN SERUM. THEREFORE, PLEASE NOTE THAT IT
IS A POTENTIALLY BIOHAZARDOUS MATERIAL.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES- IMMEDIAELY FLUSH THE EYES WITH LARGE AMOUNTS OF FRESH
WATER FOR AT LEAST 15 MIN. WHILE HOLDING OPEN EYE LIDS. SKIN-
WHILE REMOVING CONTAMINATED CLOTHING, FULSH THE CONTAMINATED ARE
WITH LARGE A MOUNTS OF FRESH WATER. INGESTION- KEEPVICTIM WARM AND
CALM. OBTAIN IMMEDIATE MEDICAL ASSISTANCE.INHALATION- REMOVE TO
FRESH AIR. ASSIST WITH BREATHING SUPPORT MEASURES IF NEEDED.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA AS APPROPRIATE FOR SITE SPECIFIC
CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP PRODUCT COOL AND DRY. STORE IN A
SEALED CONDITION.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:EYEWASH AND DELUGE SHOWER FACILITIES.
Work Hygienic Practices:WASH HAANDS AFTER WORKING WITH THIS PRODUCT.
Supplemental Safety and Health
MANUFACTURER'S MSDS IS OF EXTREMELY POOR QUALITY.
================== Physical/Chemical Properties ==================
HCC:T6
Solubility in Water:SOLUBLE
Appearance and Odor:DRIED SERUM IN VIAL. NO NOTED ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MEROPA 3200,02349
Resp. Party Other MSDS Num.:GEN05ET
CAGE:1D3L3
CAGE:1D3L3
============= Composition/Information on Ingredients =============
Ingred Name:PRODUCTS REPRESENTED BY MSDS MAY CONTAIN ONE OR MORE OF
INGREDIENTS 2-6 IN THE CONCENTRATION RANGES LISTED
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, SOLVENT-DEWAXED HEAVY
PARAFFINIC (SEVERE SOLVENT-REFINING AND/OR HYDROTREATMENT);
(SOLVENT-DEWAXED HEAVY PARAFFINIC PETROLEUM DISTILLATES)
CAS:64742-65-0
RTECS #:PY8038501
Minumum % Wt:49.99
Maxumum % Wt:79.99
Ingred Name:RESIDUAL OILS (PETROLEUM), HYDROTREATED
CAS:64742-57-0
Minumum % Wt:10.
Maxumum % Wt:99.99
Ingred Name:SOLVENT DEASPHALTED RESIDUAL OIL (PETROLEUM)
CAS:64741-95-3
Minumum % Wt:20.
Maxumum % Wt:79.99
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATMENT (SEVERE)
HEAVY PARAFFINIC; (HYDROTREATED HEAVY PARAFFINIC PETROLEUM
DISTILLATES)
CAS:64742-54-7
RTECS #:PY8035501
Minumum % Wt:20.
Maxumum % Wt:34.99
ACGIH TLV:5 MG/M3
Ingred Name:ASPHALT
CAS:8052-42-4
RTECS #:CI9900000
Minumum % Wt:35.
Maxumum % Wt:49.99
OSHA PEL:see Table Z-2
ACGIH TLV:5 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Minumum % Wt:.01
Maxumum % Wt:.09
OSHA PEL:see Table Z-2
ACGIH TLV:188 MG/M3;50 PPM
Ingred Name:ISOPROPYL ALCOHOL
CAS:67-63-0
RTECS #:NT8050000
OSHA PEL:980 MG/M3;400 PPM
ACGIH TLV:983 MG/M3;400 PPM
ACGIH STEL:1230 MG/M3;500 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL, RAT) >5 G/KG (SIMILAR PROD)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES:MAY CAUSE MINIMAL IRRIT,
EXPERIENCED AS TEMPORARY DISCOMFORT. SKIN: BRIEF CONTACT IS NOT
IRRIT. PRLNGD CONTACT, AS W/CLTHG WETTED W/MATL, MAY CAUSE DEFAT OF
SKIN OR IRRIT, SEEN AS LOCAL RE DNESS W/POSS MILD DISCOMFORT. OTHER
THAN POTNTL SKIN IRRIT EFTS NOTED ABOVE, ACUTE (SHORT TERM) ADVERSE
EFTS ARE NOT EXPECTED FROM BRIEF SKIN CONTACT; SEE OTHER EFTS,
BELOW & SECTION 11 FOR INFO REGAR DING POTNTL LONG TERM EFTS.
INHAL: VAPS/MIST, IN EXCESS OF PERMISSIBLE CONCS, OR IN UNUSUALLY
HIGH CONCS GENERATED FROM SPRAYING, HEATING MATL OR AS FROM EXPOS
IN POORLY VENTD AREAS OR CONFINED SPACES , MAY CAUSE IRRIT OF (EFTS
OF OVEREXP)
Effects of Overexposure:HLTH HAZS: NOSE & THROAT, HDCH, NAUS & DROW.
INGEST: IF MORE THAN SEVERAL MOUTHFULS SWALLOWED, ABDOMINAL
DISCOMFORT, NAUS & DIARR MAY OCCUR. SENSIT PROPERTIES: UNKNOWN.
TOLUENE APPEARS ON THE NAVY LI ST OF OCCUP CHEM REPRO HAZS. SEEK
CONSULTATION FROM APPROP HEALTH PROFESSIONALS CONCERNING LATEST HAZ
LIST INFO & SAFE HNDLG & EXPOS INFO . NO ADVERSE EFTS DOCUMENTED IN
HUMANS AS RSLT OF CHRONI C EXPOS. SECTION 11 MAY CONTAIN APPLIC
ANIMAL DATA. OTHER REMARKS: WHEN OVERHEATED, PROD MAY RELEASE
HYDROGEN SULFIDE (H2S) GAS. H2S CONCS ABOVE PERMISSIBLE CONCS CAN
CAUSE IRRIT OF EYES & RESP TRACT, HDCH, DIZZ, NAUS, VOMIT,
(SUPDAT)
Medical Cond Aggravated by Exposure:BECAUSE OF ITS DEFATTING
PROPERTIES, PROLONGED AND REPEATED SKIN CONTACT MAY AGGRAVATE AN
EXISTING DERMATITIS (SKIN CONDITION).
======================= First Aid Measures =======================
First Aid:EYES: FLUSH EYES W/PLENTY OF WATER FOR AT LEAST 15 MINUTES.
GET MED ATTN IF EYE IRRIT PERSISTS. SKIN: WASH SKIN W/PLENTY OF
SOAP & WATER FOR SEVERAL MINUTES. GET MED ATTN IF SKIN IRRIT
DEVELOPS OR PER SISTS. INGEST: IF MORE THAN SEVERAL MOUTHFULS OF
THIS MATERIAL ARE SWALLOWED, GIVE TWO GLASSES OF WATER (16 OZ). GET
MED ATTN. INHAL: IF IRRIT, HDCH, NAUS OR DROW OCCURS, REMOVE TO
FRESH AIR. GET MEDATTN IF BRTHG BECOMES DFCLT OR RESP IRRIT
PERSISTS. OTHER INSTRUCTIONS: REMOVE & DRY-CLEAN OR LAUNDER CLTHG
SOAKED OR SOILED W/THIS MATL BEFORE REUSE. DRY CLEANING OF CONTAM
CLTHG MAY BE (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:=212.8C, 415.F
415-480F
Lower Limits:NOT DETERM
Upper Limits:NOT DETERM
Extinguishing Media:USE WATER SPRAY, DRY CHEMICAL, FOAM OR CARBON
DIOXIDE TO EXTINGUISH FLAMES.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO COOL FIRE-EXPOSED CONTAINERS. WATER
OR FOAM MAY CAUSE FROTHING.
Unusual Fire/Explosion Hazard:HYDROGEN SULFIDE (H2S) MAY BE RELEASED IF
OVERHEATED.
================== Accidental Release Measures ==================
Spill Release Procedures:(TRANSPORTATION SPILLS: CHEMTREC 800-424-9300)
VENT AREA. AVOID BRTHG VAPOR. WEAR APPROP PERSONAL PROT EQUIP
INCLUDING APPROP NIOSH APPRVD RESP PROT. CONTAIN SPILL IF POSS.
WIPE UP OR ABSORB ON SUITAB LE MATL & SHOVEL UP. PREVENT ENTRY INTO
SEWERS & WATERWAYS. AVOID CONTACT W/SKIN, EYES OR CLTHG. IF MORE
THAN 5,208,333 LBS OF PROD IS SPILLED, THEN REPORT SPILL (OTHER
INFO)
======================Handling and Storage ======================
Handling and Storage Precautions:MINIMUM FEASIBLE HANDLING TEMPERATURES
SHOULD BE MAINTAINED. PERIODS OF EXPOSURE TO HIGH TEMPERATURES
SHOULD BE MINIMIZED. WATER CONTAMINATION SHOULD BE AVOIDED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AIRBORNE CONCS SHOULD BE KEPT TO LOWEST LEVELS
POSS. IF VAP, MIST OR DUST IS GENERATED & OCCUP EXPOS LIMIT OF
PROD, OR ANY COMPONENT OF PROD IS EXCEEDED, USE APPROP NIOSH APPRVD
AIR PURIFYING OR AIR S UPPLIED RESP AFTER DETERMINING THE AIRBORNE
CONC OF THE CONTAMINANT. NIOSH APPRVD AIR SUPPLIED RESPS SHOULD
ALWAYS BE WORN (OTHER INFO)
Ventilation:ADEQUATE TO MEET COMPONENT OCCUPATIONAL EXPOSURE LIMITS
(SEE INGREDIENT SECTION).
Other Protective Equipment:EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA . WORKERS SHOULD WASH EXPOSED SKIN SEVERAL TIMES DAILY
W/SOAP AND WATER. SOILED WORK CLOTHING SHOULD BE LAUNDERED OR
DRY-CLEANED.
Supplemental Safety and Health
EFTS OF OVEREXP: DIARR & PULM EDEMA. AT CONCS ABOVE 300 PPM, RESP
PARALYSIS, CAUSING UNCON & DEATH CAN OCCUR. FIRST AID PROC: MORE
EFFECTIVE THAN NORMAL LAUNDERING. INFORM INDIVIDUALS RESPONSIBLE
FOR CLEANING OF POTENTIAL HAZS ASSOC W/HNDLG CONTAM CLTHG.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NOT DETERMINED
Vapor Pres:NOT DETERMINED
Vapor Density:NOT DETERM
Spec Gravity:0.8833-0.9402
Viscosity:68-3200 CST @ 40C
Solubility in Water:NOT DETERMINED
Appearance and Odor:RED LIQUID TO OPAQUE LIQUID WITH GREEN BLOOM; ODOR
NOT DETERMINED.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
THIS MATERIAL REACTS VIOLENTLY WITH STRONG OXIDIZERS.
Stability Condition to Avoid:UNDER EXTREME TEMPERATURES OR EXTENDED
STORAGE PERIODS, HYDROGEN SULFIDE GAS MAY ACCUMULATE IN THE
HEAD-SPACE OF CONTAINER.
Hazardous Decomposition Products:TOXIC LEVELS OF CARBON MONOXIDE,
CARBON DIOXIDE, IRRITATING ALDEHYDES AND KETONES, AND COMBUSTION
PRODUCT OR COMPOUNDS OF SULFUR (MAY INCLUDE HYDROGEN SULFIDE).
=================== Toxicological Information===================
Toxicological Information:ANIMAL TOXICITY DATA: MEDIAN LETHAL DOSE -
ORAL: LD50 SIMILAR PRODUCT >5 G/KG (RAT) PRACTICALLY NON-TOXIC.
INHALATION: NOT DETERMINED. DERMAL: LD50 SIMILAR PRODUCT >3 G/KG
(RABBIT) PRACTICALLY NON-TOX IC. IRRITATION INDEX, ESTIMATION OF
IRRITATION (SPECIES). SKIN: (DRAIZE) SIMILAR PRODUCT <0.01 / 8.0
RABBIT NO APPRECIABLE EFFECT. EYES: (DRAIZE) SIMILAR PRODUCT 5.30 /
110 (RABBIT) NO APPRECIABLE EFF ECT. SENSITIZATION: NOT DETERMINED.
OTHER: NONE.
===================== Ecological Information =====================
Ecological:AQUATIC TOXICITY: LC50-96 HR SIMILAR PROD > 1000 MG/L
(RAINBOW TROUT) PRACTICALLY NON-TOXIC. EC50-48 HR SIMILAR PROD
>1000 MG/L (DAPHNIA MAGNA) PRACTICALLY NON-TOXIC. EC50-96 HR
SIMILAR PROD 25 MG/L S ELENASTRUM (CELL DENS.) SLIGHTLY TOXIC.
LC50-96 HR SIMILAR PROD >1000 MG/L MYSID SHRIMP (MARINE).
PRACTICALLY NON-TOXIC. LC50-96 HR SIMILAR PROD >1000 MG/L
SHEEPSHEAD MINNOW (MARINE) PRACTICALLY NON-T OXIC. MOBILITY: NOT
DETERMINED. PERSISTENCE & BIODEGRADABILITY: THIS PROD IS ESTIMATED
TO HAVE SLOW (<30%) RATE OF BIODEGRADATION IN TEST FOR READY
BIODEGRADATION. POTENTIAL TO BIOACCUMULATE: NOT EVAL UATED.
REMARKS: NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FED, STATE & LOCAL REGS
.THIS PROD HAS BEEN EVALUATED FOR RCRA CHARACTS & DOES NOT MEET
CRITERIA OF HAZ WASTE IF DISCARDED IN ITS PURCHASED FORM. UNDER
RCRA, IT IS RESPONS IBILITY OF USER OF PROD TO DETERMINE AT TIME OF
DISPOSAL, WHETHER PROD MEETS RCRA CRITERIA FOR HAZ W ASTE.
=================== MSDS Transport Information ===================
Transport Information:DOT - PROPER SHIPPING NAME: NOT REGULATED. IMDG -
PROPER SHIPPING NAME: NOT REGULATED. ICAO - PROPER SHIPPING NAME:
NOT REGULATED. TDG - PROPER SHIPPING NAME: NOT REGULATED.
===================== Regulatory Information =====================
SARA Title III Information:SECTION 302/304 EXTREMELY HAZARDOUS
SUBSTANCES: NONE. SECTION 311 HAZARDOUS CATEGORIZATION: N/A.
SECTION 313 TOXIC CHEMICAL: NONE.
Federal Regulatory Information:CERCLA 102(A)/DOT HAZ SUBSTANCES:
TOLUENE, CAS #:108-88-3, 0.01-0.09%. (ALSO DOT HAZ SUSBSTANCE).
CERCLA/DOT RQ: 1000. THIS PROD, OR ITS COMPONENTS, ARE LISTED ON OR
ARE EXEMPT FROM TOXIC SUBSTANCE CO NTROL ACT (TSCA) CHEM SUBSTANCE
INVENTORY. INTERNATIONAL REGS: EXPORT NOTIFICATION (TSCA-12B): THIS
PROD MAY BE SUBJECT TO EXPORT NOFITICATION UNDER TSCA SECTION
12(B); CONTAINS ISOPROPYL ALCOHOL. WHM IS CLASSIFICATION: NOT
CONTROLLED. THIS PROD OR ITS COMPONENTS ARE LISTED ON OR ARE EXEMPT
FROM CANA DIAN DOMESTIC SUBSTANCE LIST (DSL).
EINECS/AUSTRALIA/JAPAN INVENTORY STATUS: NOT DETERMINED.
State Regulatory Information:A RISK ASSESSMENT HAS BEEN PERFORMED ON
THIS PRODUCT WHICH INDICATES THAT NO CA PROPOSITION 65 WARNINGS ARE
REQD. CA PROPOSITION 65: THE FOLLOWING DETECTABLE COMPONENTS OF
THIS PROD ARE SUBSTANCES OR BELON TO CLASSES OF SUBSTANCES, KNOWN
TO THE STATE OF CA TO CAUSE CANCER &/OR REPRO TOXICITY: TOLUENE,
108-88-3.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SL-95 HEMATOXYLIN STAIN,GILL III
CAGE:0B3E9
CAGE:0B3E9
============= Composition/Information on Ingredients =============
Ingred Name:ACETIC ACID (GLACIAL)
CAS:64-19-7
RTECS #:AF1225000
Fraction by Wt: 6%
OSHA PEL:25 MG/CUM
ACGIH TLV:25 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 63.06%
Ingred Name:HEMATOXYLIN
CAS:517-28-2
RTECS #:MH7875000
Fraction by Wt: 0.6%
Ingred Name:SODIUM IODATE
CAS:7681-55-2
RTECS #:NN1400000
Fraction by Wt: 0.06%
Ingred Name:ALUMINUM SULFATE HEXADECAHYDRATE
CAS:16828-11-8
Fraction by Wt: 5.28%
Ingred Name:ETHYLENE GLYCOL, GLYCOL
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 25%
Other REC Limits:10 MG/CUM
OSHA PEL:50 PPM
ACGIH TLV:C 127 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 3310 MG/KG (ACETIC ACID)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE IRRITATION OF NOSE & THROAT,
CNS INVOLVEMENT, LIVER DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, CHRONIC BRONCHITIS, HEADACHE,
ABDOMINAL DISCOMFORT, NAUSEA, VOMITING, DIZZINESS, BLURRING VISION.
Medical Cond Aggravated by Exposure:CHRONIC RESPIRATORY DISEASE,
PRE-EXISTING EYE PROBLEMS, PRE-EXISTING SKIN DISORDERS,
LIVER/KIDNEY DISEASE.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: IMMEDIATELY FLUSH W/LARGE QUANTITIES OF RUNNING
WATER. INHALATION: REMOVE TO FRESH AIR. GIVE CPR IF NEEDED.
INGESTION: DILUE IMMEDIATELY W/WATER/MILK. INDUCE VOMITING. OBTAIN
MEDICAL ATTENT ION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:ABC DRY CHEMICAL, CO2, WATER.
Fire Fighting Procedures:WEAR A SELF-CONTAINED BREATHING APPARATUS.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH W/LARGE QUANTITIES OF WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT FROM PHYSICAL DAMAGE, ELEVATED
TEMPS. STORE AWAY FROM INCOMPATIBLE MATERIALS.
============= Exposure Controls/Personal Protection =============
Ventilation:NORMAL ROOM VENTILATION IS ADEQUATE AT AMBIENT TEMPS.
Other Protective Equipment:LAB COAT/APRON
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Melt/Freeze Pt:M.P/F.P Text:32F
Spec Gravity:1
Solubility in Water:COMPLETE
Appearance and Odor:DARK PURPLE LIQUID W/SLIGHT ACETIC ACID ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, SULFURIC ACID, PERCHLORIC ACID.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:S64R535 DEEP RED
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTOXYETHANOL (ETHYLENE GLYCOL MONOBUTYL ETHER), BUTYL
CELLOSOLVE, BUTYL GLYCOL, GLYCOL ETHER EB * 96-3 *
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 3%
Other REC Limits:25 PPM (SKIN)
OSHA PEL:50 PPM (SKIN)
ACGIH TLV:25 PPM (SKIN)
Ingred Name:ETHYLENE GLYCOL, GLYCOL *96-3*
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 3%
Other REC Limits:10 MG/CUM
OSHA PEL:50 PPM
ACGIH TLV:C 127 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:DIMETHYL AMINOETHANOL
CAS:108-01-0
RTECS #:KK6125000
Fraction by Wt: 3%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 75.2%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION TO EYES, SKIN & UPPER
RESPIRATORY SYSTEM. PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE
ADVERSE EFFECTS TO THE LIVER, URINARY & BLOOD-FORMING SYSTEMS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, NAUSEA, DIZZINESS,
REDNESS, ITCHING, BURNING SENSATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. KEEP WARM
& QUIET. SKIN: WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH W/WATER
FOR 15 MINS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:CO2, DRY CHEMICAL, ALCOHOL FOAM
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT W/SCBA. WATER
SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE. USE WATER TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE DUE TO THE
BUILDUP OF PRESSURE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES. VENTILATE & REMOVE
W/INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
TRANSFER ONLY TO APPROVED CONTAINERS W/COMPLETE & APPROPRIATE
LABELING. DON'T TAKE INTERNALLY.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID BREATHING VAPOR
& SPRAY MIST. AVOID CONTACT W/SKIN & EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A PROPERLY FITTED ORGANIC VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA. WHEN SANDING/ABRADING THE DRIED
FILM, WEAR DUST/MIST RESPIRATOR APPROVED BY NIOSH/MSHA.
Ventilation:LOCAL/GENERAL EXHAUST VENTILATION
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
PH: 8.5-9.5
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212-388F
Vapor Density:>1
Spec Gravity:1.1-1.4
pH:(SUPP)
VOC Grams/Liter:2.99
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:61-97
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:EXTREME HEAT.
Hazardous Decomposition Products:BY FIRE: CO2, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:NOT HAZARDOUS. INCINERATE IN APPROVED FACILITY.
DON'T INCINERATE CLOSED CONTAINERS. DISPOSE OF IAW/FEDERAL, STATE &
LOCAL REGULATIONS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LAC LUST HOT SPRY OLIVE DRAB 34088 ID788410
Preparer's Name:W.A. ELLISON
CAGE:PRATT
CAGE:PRATT
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 10%
Other REC Limits:LFL 1.0/ UFL 7.0
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE (SARA III)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 5%
Other REC Limits:LFL 1.0/UFL 6.7
OSHA PEL:100 PPM/125 STEL
ACGIH TLV:100 PPM/125STEL 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: < 5%
Other REC Limits:LFL 1.7/UFL 7.1
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:N-HEPTANE
CAS:142-82-5
RTECS #:MI7700000
Fraction by Wt: 5%
Other REC Limits:LFL 1.0/UFL 7.0
OSHA PEL:500 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9293
Ingred Name:HEXANE (N-HEXANE)
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: < 1%
Other REC Limits:LFL 1.0/UFL 8.0
OSHA PEL:500 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:N-BUTYL ALCOHOL (SARA III)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 5%
Other REC Limits:LFL 1.4/UFL 11.2
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 5%
Other REC Limits:LFL 3.0/UFL 13.0
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:NITROCELLULOSE
CAS:9004-70-0
RTECS #:QW0975100
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE
CAS:14464-46-1
RTECS #:VV7325000
Fraction by Wt: < 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.05 MG/M3 RDUST9293
Ingred Name:TALC (CONTAINING NO ASBESTOS)
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST; 9192
Ingred Name:ISOBUTYL ACETATE (SARA III)
CAS:110-19-0
RTECS #:AI4025000
Fraction by Wt: 25%
Other REC Limits:LFL 2.0/UFL 11.0
OSHA PEL:150 PPM
ACGIH TLV:150 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPANOIC ACID, 3-ETHOXY-ETHYL ESTER (VP 1 MM HG @ 20C)
(SARA 313 REPORTABLE)
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: < 5%
Other REC Limits:NONE SPECIFIED
Ingred Name:DI-SEC-OCTYL PHTHALATE (DI-2-ETHYLHEXYL-PHTHALATE)(SARA
III)
CAS:117-81-7
RTECS #:TI0350000
Fraction by Wt: < 1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3/10 STEL
ACGIH TLV:5 MG/M3; 9192
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:VOC 4.94 LB/GAL LESS WATER & NEGLIGIBLY PHOTOCHEMICALLY
REACTIVE MATERIALS 593 G/L LESS WATER
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
Ingred Name:VOC 17.27 LB/GAL SOLIDS 2072 G/L SOLIDS
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES
Health Hazards Acute and Chronic:COULD CAUSE SEVERE IRRITATION IF
SWALLOWED, INHALED, GETS INTO EYES, OR ABSORBED THROUGH SKIN. OTHER
EFFECTS: LUNG DISEASE, DAMAGE TO LIVER, KIDNEYS, BLOOD, PERIPHERAL
NERVOUS SYSTEM, PERMANENT BRAIN DAMAGE & DEATH.
Explanation of Carcinogenicity:DI-PHTHALATE AND CRYSTALLINE SILICA HAVE
BEEN LISTED AS POTENTIAL CARCINOGENS BY THE IARC & NTP.
Effects of Overexposure:NAUSEA, VOMITING, HEADACHES, DIZZINESS,
DEPRESSION, & CONFUSION. ALSO SIGNS OF SEVERE IRRITATION IF
SWALLOWED, INHALED, GETS INTO EYES, OR ABSORBED THROUGH THE SKIN.
Medical Cond Aggravated by Exposure:CHEMICAL PNEUMONITIS, CENTRAL
NERVOUS SYSTEM DEPRESSION, LUNG DISEASE, DAMAGE TO LIVER, KIDNEYS,
BLOOD, PERIPHERAL NERVOUS SYSTEM, RESPIRATORY CONDITIONS,
PERMANENT BRAIN & NERVS SYS DAMAGE & DEATH.
======================= First Aid Measures =======================
First Aid:SWALLOWING: DO NOT INDUCE VOMITING. CALL POISON CONTROL
CENTER IMMED. INHALATION: REMOVE TO FRESH AIR IMMED. IF BREATHING
STOPPED, GIVE CPR & KEEP WARM & QUIET. EYE: FLUSH WITH LRG AMTS OF
WATER FOR 1 5 MIN LIFTING UPPER LIDS CONTINUOUSLY. SKIN: IMMED
FLUSH CONTAMINATED AREA WITH LRG AMTS OF WATER. REMOVE CONTAMINATED
CLOTHES AS WATER IS APPLIED. GET MEDICAL ATTN IMMED FOR ANY OF
THESE CONDITIONS.
===================== Fire Fighting Measures =====================
Flash Point:-9F/-23C
Lower Limits:SEE INGRED.
Upper Limits:SEE INGRED.
Extinguishing Media:USE NFPA CLASS B FIRE EXTINGUISHER TO EXTINGUISH
FLAMMABLE LIQUID FIRES. POLYMER FOAM IS PREFERRED FOR LARGE FIRES.
Fire Fighting Procedures:FF SHOULD WEAR SELF-CONTAINED BREATHING
APPARATUS. WATER MAY BE INEFFEC BUT USE TO COOL EXPOSED CONTAINER
TO PREVENT BUILDUP & POSSIBLE AUTO-IGNITE/EXPLOSION.
Unusual Fire/Explosion Hazard:OVEREXPOSURE TO DECOMPOSITON PRODUCTS MAY
CAUSE HEALTH HAZARD. SYMPTOMS MAY NOT BE IMMEDIATELY APPARENT.
OBTAIN MEDICAL ATTENTION.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR RESPIRATOR, APPROPRIATE BODY PROTECTION.
KEEP SPECTATORS AWAY, ELIMINATE ALL IGNITE SOURCES, CONTAIN SPILL
W/INERT MATERIAL, TRANSFER LIQ TO COV METAL CONTAINERS FOR
DISPOSAL. USE ONLY NON-SPARKI NG TOOLS. PREVENT CONTAMINATION OF
ANY GROUNDWATER
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 95 DEGREES F. STORE
LARGE QUANTITIES IN COMPLIANCE WITH OSHA 29CFR1910.106.
Other Precautions:EMPTY CONTAINERS MUST NOT BE WASHED & RE-USED FOR ANY
PURPOSE. CONTAINERS SHOULD BE GROUNDED & BONDED TO RECEIVING
CONTAINER. DO NOT WELD, BRAZE OR CUT ON EMPTY CONTAINER. NEVER USE
PRESSURE TO EMPTY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WELL VENTILATED AREAS MAY NOT REQUIRE
RESPIRATORY PROTECTION. IN RESTRICTED AREAS USE APPROVED ORGANIC
VAPOR RESPIRATOR. FOR SPRAYING USE MECHANICAL PREFILTER. IN
CONFINED AREAS USE NIOSH/MSHA APPROVE D AIR SUPPLIED RESPIRATOR.
Ventilation:DILUTE & LOCAL EXHAUST VENTILATION TO CONTROL CONCENTRATION
OF HAZARDOUS INGREDIENTS.
Work Hygienic Practices:EYEWASH FACILITY, SAFETY SHOWER. DO NOT TAKE
INTERNALLY. CLOSE CONTAINER AFTER EACH USE & KEEP AWAY FROM
CHILDREN.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:139 TO 338F
Vapor Density:> THAN AIR
Spec Gravity:1.1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:71
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, ALKALINE OR OXIDIZING MATERIALS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT AND SOURCES OF
IGNITION.
Hazardous Decomposition Products:BURNING, HEAT BY WELDING, CUTTING,
WILL PRODUCE SMOKE, CARBON MONOXIDE, CARBON DIOXIDE,& OXIDES OF
NITROGEN MAY GENERATE
Conditions to Avoid Polymerization:KEEP AWAY FROM HEAT SPARKS AND
FLAME.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE & LOCAL LAWS.
INCINERATE ONLY IN EPA PERMITTED FACILITY. DO NOT INCINERATE CLOSED
CONTAINERS. OBSERVE PRECAUTIONS FOR DISPOSAL OF FLAMMABLE
MATERIALS. CONTAMINATED ABSO RBANT MAY BE DISPOSED IN HAZARDOUS
WASTE LANDFILL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PF110-H101 BLACK
CAGE:03FB0
CAGE:03FB0
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE METHACRYLIC ACID COPCLYMER
CAS:25053-53-6
Minumum % Wt:0.
Maxumum % Wt:100.
Ingred Name:RESIDUAL METHYLACRYLIC ACID
CAS:79-41-4
RTECS #:OZ2975000
= Wt:.05
ACGIH TLV:20 PPM
Ingred Name:BLACK PIGMENT
CAS:1333-86-4
RTECS #:FF5800000
Minumum % Wt:0.
Maxumum % Wt:10.
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:LIGHT STABILIZER
CAS:52829-07-9
Minumum % Wt:0.
Maxumum % Wt:1.
Ingred Name:ANTIOCIDANT/STABILIZER
CAS:6683-19-8
RTECS #:DA8340900
Minumum % Wt:0.
Maxumum % Wt:1.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE IRRITATION TO
UPPER RESPIRATORY TRACT. SKIN: MAY CAUSE IRRITATION AND ALLERGIC
REACTION. INGESTION: NOT LIKELY. MAY CAUSE IRRITATION TO THE
GASTROINTESTINAL TRACT. EYES: MAY CAUS E IRRITATION.
Medical Cond Aggravated by Exposure:
======================= First Aid Measures =======================
First Aid:INGESTION:IF LARGE AMMOUNT SWALLOWED, GIVE SEVERAL GLASSES OF
WATER.CONTACT MEDICAL PERSONNEL FOR FURTHER ASSISTANCE.IF
UNCONCIOUS/CONVULSING,DO NOT GIVE ANYTHING BY MOUTH.EYE CONTACT:
FLUSH WITH PLEN TY OF RUNNING WATER FOR AT LEAST 15 MINITUES.HOLD
THE EYELIDS APART TO ENSURE THE RINSING OF ENTIIRE SURFACE.SEEK
MEDICAL ATTENTION IF EYE IRRITATION OCCURS.SKIN CONTACT:FLUSH ALL
AREAS WITH PLENTY OF WATER FOR SEVERAL MINITUES. REMOVE/CLEAN
CONTAMINATED CLOTHING/SHOES.SEEK MEDICAL ATTENTION IF SKIN
IRRITATION OCCURS. INHALATION:REMOVE TO FRESH AIR.SEEK MEDICAL
ATTENTION IF RESPIRATORY IRRITATION OCCURS/ BREATHING BECOMES
DIFFICULT.
===================== Fire Fighting Measures =====================
Lower Limits:30 GRAMS/CM
Extinguishing Media:WATER, FOAM, CARBON DIOXIDE, DRY CHEMICALS. COOL
FIRE EXPOSED CONTAINERS WITH WATER.
Fire Fighting Procedures:PRODUCTS OF COMBUSTION MAY BE TOXIC. AVOID
BREATHING FUMES. FIREFIGHTERS SHOULD BE QQUIPPED WITH
SELF-CONTAINED BREATHING APPARATUS. DO NOT ENTER CONFINED FIRE
SPACE WITHOUT FULL BUNKER GEAR (HELMET W ITH FACE SHIELD, BUNKER
BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:DUST CAN FORM AN EXPLOSIVE MIXTURE WITH
AIR. ELLIMINATION OF SOURCES OF IGNITION IS ESSENTIAL.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP TO AVOID SLIPPING HAZARD. USE
APPROPIATE PERSONAL PROTECTIVE EQUIPMENT DURING CLEANUP.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL DRY PLACE. KEEP
CONTAINERS CLOSED TO PREVENT CONTAMINATION AND ACCUMULATION OF
MOISTURE.
Other Precautions:CARBON BLACK IS DESIGNATED A NUISANCE DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH/MSHA APPROVED RESPIRATOR EQUIPPED
WITH THE APPROPIATE FILTER FOR PARTICULATE DUST EXPOSURE.
Ventilation:LOCAL VENTILATION SHOULD BE USED OVER PROCESSING EQUIPMENT.
Other Protective Equipment:LONG SLEEVE COTTON SHIRT AND PANTS ARE
RECOMMENDED TO PREVENT SKIN CONTACT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:=80.C, 176.F
B.P. Text:176-221F
Spec Gravity:> 0.93
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK FINELY DIVIDED POWDER MILD METHACRYLIC ACID
ODOR
Percent Volatiles by Volume:NEGLIGIBLE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:THE MATERIALS ARE NORMALLY STABLE AND
DECOMPOSE ONLY IN EXTREME CASES SUCH AS FIRE.
Hazardous Decomposition Products:OXIDES OF NITROGEN, CARBON AND MIXTURE
OF ORGANIC COMPOUND ARE THE EXPECTED IN THE PRESSANCE OF LARGE
AMMOUNTS OF AIR. CARBON MONOXIDE AND HYDROCARBON OXIDATION.-ORGANIC
ACIDS, ALDEHYDES AND ALCOHOLS.
=================== Toxicological Information===================
Toxicological Information:TOXICITY IS EXPECTED TO BE LOW BASED ON
NEGLIGIABLE WATER SOLUBILITY.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREFERED OPTIONS FOR DISPOSAL ARE (1) RECYCLING,
(2) INCINERATION WITH ENERGY RECOVERY, AND (3) LANDFILL. THE HIGH
FUEL VALUE OF THIS PRODUCT MAKES OPTION 2 VERY DESIRABLE FOR
MATERIAL THAT CANNOT BE RECYCLED. TREATMENT, STORAGE,
TRANSPORTATION AND DISPOSA; MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND PROVINCIAL AND LOCAL REGULATIONS.
===================== Regulatory Information =====================
SARA Title III Information:CARBON BLACK, CAS#133-86-4, HIGHEST % BY
WEIGHT 2.50.
State Regulatory Information:
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BLEND-A-COLOR TONERS, 744-1506 RED
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA 313) (CERCLA). VP: 0.1
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 27%
OSHA PEL:C 50 PPM (MFR)
ACGIH TLV:C 50 PPM,VAPOR; 9495
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:OCTYLPHENOXY POLYETHOXY ETHANOL
CAS:9036-19-5
RTECS #:RI0710000
Fraction by Wt: 13%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TALC (CONTAINING NO ASBESTOS)
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 27%
OSHA PEL:20 MPPCF Z-3
ACGIH TLV:2 MG/M3 RDUST; 9495
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 14.7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT: URINARY SYS. RATS EXPOSED TO TITANIUM DIOXIDE DUST
AT 250 MG/M3 DEVELOPED LUNG CANCER, HOWEVER, SUCH (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: EXPOSURE LEVELS ARE NOT ATTAINABLE IN THE WORKPLACE.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: LIMITS FOR NUISANCE DUSTS ARE ACGIH TLV 10
MG/M3 (TOTAL DUST), 3 MG/M3 (RESPIRABLE (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: FRACTION), OSHA PEL 15 MG/M3 (TOTAL DUST), 5 MG/M3
(RESPIRABLE FRACTION). KEEP CNTNR CLOSED WHEN NOT IN (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: USE. TRANSFER ONLY TO APPROVED CONTAINERS
W/COMPLETE AND APPROPRIATE LABELING. DO NOT TAKE INTERNALLY. (ING
12)
RTECS #:9999999ZZ
Ingred Name:ING 11: KEEP OUT OF THE REACH OF CHILDREN. WARNING: THESE
PRODS CNTN A CHEMICAL(S) KNOWN TO THE STATE OF CA TO (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: CAUSE CANCER. BLACK, BLUE, GREEN, RED, RED OXIDE,
AND MAROON TONERS ALSO CONTAIN CHEMICAL(S) KNOWN TO (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: THE STATE OF CALIFORNIA TO CAUSE BIRTH DEFECTS OR
OTHER REPRODUCTIVE HARM.
RTECS #:9999999ZZ
Ingred Name:RESP PROT: NIOSH FOR DUST WHICH MAY BE GENERATED FROM THIS
PRODUCT, UNDERLYING PAINT, OR THE ABRASIVE.
RTECS #:9999999ZZ
Ingred Name:VENT: REFER TO OSHA STANDARDS 1910.94, 1910.107, 1910.108.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPOS MAY BE BY INHAL &/SKIN/EYE
CONTACT, DEPENDING ON CONDITIONS OF USE. TO MINIMIZE EXPOS, FOLLOW
RECOMMENDATIONS FOR PROPER USE, VENT, & PERS PROT EQUIP. ACUTE:
IRRIT OF EYES, SKIN & UPPER RESP SYS . IN A CONFINED AREA VAPORS IN
HIGH CONC MAY CAUSE HDCH, NAUS/DIZZ. SIGNS & SYMPS OF OVEREXP:
REDNESS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: & ITCHING/BURNING SENSATION MAY
INDICATE EYE/EXCESSIVE SKIN EXPOS. CHRONIC: ETHYLENE GLYCOL IS
CONSIDERED AN ANIMAL TERATOGEN. IT HAS BEEN SHOWN TO CAUSE BIRTH
DEFECTS IN RATS & MICE AT HIGH DOSES WHEN GIVEN IN DRINKING
WATER/BY GAVAGE. THERE IS NO EVID TO INDICATE IT CAUSES BIRTH
DEFECTS IN HUMANS. (SUPDAT)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL: IF AFFECTED, REMOVE FROM EXPOS. RESTORE BRTHG. KEEP
WARM & QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY W/SOAP & H*2O.
REMOVE CONTAMD CLTHG & LAUNDER BEFORE RE-USE. EYES: FLUSH W/LRG
AMTS OF H*2O FOR AT LEAST 15 MIN. GET MED ATTN. INGEST: NEVER GIVE
ANYTHING BY MOUTH TO AN UNCON PERS. GIVE CONSCIOUS PATIENT SEVERAL
GLASSES OF H*2O. IF VOMIT IS NOT SPONTANEOUS, INDUCE VOMIT BY
HAVING (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:232F,111C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL FOAM.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER SPRAY MAY BE INEFT. IF H*2O IS USED, FOG NOZZLES ARE PREF.
H*2O MAY BE USED TO COOL CLSD CNTNRS (SUPDAT)
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO THE
BUILD-UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE ONLY WITH ADEQUATE VENTILATION.
AVOID BREATHING VAPOR AND SPRAY MIST. AVOID CONTACT WITH SKIN AND
EYES.
Other Precautions:THESE PRODS MAY CONTAIN MATLS CLASSIFIED AS NUISANCE
PARTICULATES (LISTED "AS DUST" IN SECTION 2) WHICH MAY BE PRESENT
AT HAZS LEVELS ONLY DURING SANDING/ABRADING OF DRIED FILM. IF NO
SPECIFIC DUSTS A RE LISTED IN SECTION 2, APPLIC (ING 9)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERS EXPOS CANNOT BE CONTROLLED BELOW APPLIC
LIMS BY VENT, WEAR A PROPERLY FITTED ORG VAP/PARTICULATE RESP
APPRVD BY NIOSH FOR PROT AGAINST MATLS IN SECTION 2. WHEN
SANDING/ABRADING DRIED FILM, WEA R A DUST/MIST RESP APPRVD BY (ING
15)
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPTABLE IF EXPOS TO MATLS IN
SECTION 2 IS MAINTAINED BELOW APPLICABLE EXPOS LIMS. (ING 16)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
PH: 8.3-9.0. FIRE FIGHT PROC: TO PVNT PRESS BUILD-UP & POSS
AUTOIGNITION/EXPLOSION WHEN EXPOSED TO EXTREME HEAT. FIRST AID
PROC: PATIENT GENTLY TOUCH BACK OF HIS THROAT W/ FINGER. KEEP
AIRWAY CLEAR. S EEK MED ATTN. EFTS OF OVEREXP: PRLNG OVEREXP TO
SOLV INGREDS IN SECTION 2 MAY CAUSE ADVERSE EFTS TO LIVER & (ING 7)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.33
pH:SUPDAT
VOC Grams/Liter:3.63
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:25-62
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THESE PRODS MAY BE HAZS AS DEFINED
UNDER RCRA 40 CFR 261. INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINER. DISPOSE OF IN ACCORDANCE WITH FEDERAL,
STATE, AND LOCAL REGULA TIONS REGARDING POLLUTION.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:METCO 405,405NS WIRE;THERMAL SPRAY METALLIC WIRE
CAGE:01FK3
CAGE:01FK3
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM (SARA 313)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 DUST
ACGIH TLV:10 MG/M3 DUST; 9495
Ingred Name:NICKEL (SARA 313) (CERCLA)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 80%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9495
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV FOR WELDING FUMES IS 5MG/M3
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES:ABRASIVE ACTION MAY CAUSE
IRRITATION.SKIN:ABRASIVE ACTION MAY CAUSE IRRITATION.INGEST:MAY
CAUSE GI TRACT IRRITATION.INHAL:MAY CAUSE RESPIRATORY
IRRITATION,CNS DEPRESSION AND PNEUMOCONIOSIS.UNDERNORMAL
USE,ALUMINUM OXIDE MAY BE FORMED.CHRONIC:MAY CAUSE CANCER OF THE
LUNGS AND NASAL SINUSES.
Explanation of Carcinogenicity:NIKEL IS CLASSIFIED IARC-1 AND
NTP-AC(ANTICIPATED CARCINOGEN).
Effects of Overexposure:INGEST:LOSS OF MUSCULAR
COORDINATION,CONFUSION,CONVULSION.SKIN:DERMATITIS.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING
RESPIRATORY,EYE,SKIN,CNS AND GI TRACT AILMENTS MAY BE AT INCREASED
RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH SOAP AND
WATER.CALL DOCTOR IF NEEDED.EYES:FLUSH WITH WATER FOR 15
MINUTES.CALL DOCTOR IF NEEDED.INHAL:REMOVE TO FRESH AIR.GIVE OXYGEN
OR ARTIFICIAL RESPIRAT ION IF NEEDED.INGEST:DO NOT INDUCE
VOMITING.GET PROMPT QUALIFIED MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:TREAT AS A METAL FIRE.USE CLASS D FIRE
EXTINGUISHANTS.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:THE FINELY DISPURSED DUST FROM THIS
PRODUCT IS A FIRE OR EXPLOSION HAZARD IN THE PRESENCE OF SOURCES OF
IGNITION.ALUMINUM IS A FLAMMABLE SOLID.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP LOOSE OR SMALL PIECES OF WIRE;PLACE
IN AN APPROPRIATE CONTAINER FOR REUSE OR DISPOSAL.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY,WELL-VENTILATED
PLACE.KEEP CONTAINER CLOSED WHEN NOT IN USE.KEEP AWAY FROM
INCOMPATIBLE MATERIALS.
Other Precautions:STORE IN A MANNER TO MINIMIZE BREAKAGE OF
CONTAINERS.IN THE FORM OF SOLID WIRE,THIS ITEM REPRESENTS
NEGLIGIBLE INHAL,INGEST AND SKIN CONTACT HAZARD.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE ENVIRONMENTAL CONTROLS ARE LACKING OR IN
ENCLOSED SPACES USE EITHER A SELF-CONTAINED BREATHING APPARATUS OR
A NIOSH/MSHA APPROVED RESPIRATOR FOR DUST OR FUMES,DEPENDING ON THE
AIRBORN CONCENTRAT ION.
Ventilation:USE WITH LOCAL EXHAUST.
Other Protective Equipment:ALUMINIZED APRON,FOR PLASMA SPRAYING.PROVIDE
A LOCAL EYE WASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS.SEPERATE WORK CLOTHES FROM STREET
CLOTHES.LAUNDER WORK CLOTHES BEFORE REUSE.KEEP FOOD OUT OF THE WORK
AREA.
Supplemental Safety and Health
TARGET ORGANS:(ALUMINUM)RESPIRATORY TRACT,GI TRACT,SKIN AND
EYES.NICKEL:RESPIRATORY TRACT,CNS,GI TRACT,SKIN AND EYES.LENS
SELECTION IS AS FOLLOWS:COMBUSTION SPRAYING-SHADE #5;PLASMA
SPRAYING <40KW-SHA DE #9;40-60KW-SHADE #10;>60KW-SHADE #11.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:1300-2500F
Solubility in Water:INSOLUBLE
Appearance and Odor:WIRE;NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS,SULFUR,SELENIUM,NICKEL NITRATE,WOOD AND OTHER COMBUSTIBLES.
Stability Condition to Avoid:ALUMINUM IS A FLAMMABLE SOLID;DO NOT
EXPOSE TO WATER, OR MOISTURE.
Hazardous Decomposition Products:OZONE,NITRIC OXIDE(FROM PLASMA FLAME).
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: 1300 HIGH TEMPERATURE COATING
Cage: 9D157
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 9D157
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: YES
OSHA: NO
Effects of Exposure: ACUTE: NAUS, DIZZ, HDCH, & CONVULSIONS. SYMPS OF
OVEREXP: INHAL: VAPS & MIST IRRITATE NOSE & THROAT. HIGHER CONCS MAY
CAUSE HDCH, NAUS, VOMIT, KIDNEY & LIVER DMG & COMA. SKIN/EYES:
BURNING SENSATION F ROM VAP/LIQ. DERM, SENSITIZ. LIQ & MISTS MAY SEV
IRRITATE/DMG EYES. ABSORB THRU SKIN: PRLNGD CONT (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: VINYL ACETATE: IARC MONOGRAPHS, VOL 63, PG 443,
1995: GROUP 2B.
Signs And Symptions Of Overexposure: HLTH HAZ: W/SKIN CAN CAUSE DEFAT
W/RESULTANT IRRIT & DERM. BRIEF CONT MAY DRY SKIN. INGEST: TOXIC IF
SWALLOWED. CAN CAUSE BURNING SENSATION, VOMIT, DIARR, DROW & PERHAPS
UNCON. EFTS OF RPTD OVEREXP: N O DATA AVAIL. VINYL CHLORIDE HAS BEEN LISTED
AS CARCIN IN NTP ANNUAL RPT ON CARCINS, IN IARC MONO & BY OSHA.
Medical Cond Aggravated By Exposure: ASTHMA AND SKIN ALLERGIES.
First Aid: EYE CONT: FLUSH IMMED W/FRESH WATER BY EYE WASH APPARATUS/BY HAND
FOR @ LST 15 MINS. SEEK MED ATTN. SKIN CONT: WASH IMMED W/WATER. THEN WASH
W/SOAP & WATER, RINSE IMMED. SEEK MED ATTN. INHAL: MOVE TO FRESH AIR;
ARTF RESP IF NEC. SEEK MED ATTN. INGEST: SEEK MED ATTN. RECS TO PHYS: IN
ACUTE CASE SEEK MED ATTN IMMED. FOR WORKERS WHO MAY BE EXPOS REGULARLY,
PROVIDE DETAILED PERIODIC EXAMINATIONS.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL TYPES OF IGNITION SOURCES. PROVIDE
SUFFICIENT VENTILATION. PROTECT CLEAN-UP PERSON W/8540 3M CORP RESPIRATOR
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: USE METAL CNTNR MARKED "DO NOT REUSE". PUT MATL IN THIS
CNTNR. USE VERMICULITE OR OTHER INERT ABSORBENT. KEEP AWAY FROM SEWER. NOTE:
DISPOSE OF ALL WASTES I/A/W FEDERAL, STATE AND LOCAL REGULATIONS.
Handling And Storage Precautions: PROTECT AGAINST PHYSICAL DMG TO CNTNRS &
SPILLAGE. STORE IN COOL WELL VENTILATED AREA W/SPRINKLER SYS. KEEP AWAY FROM
HEAT. POST NO SMOKING SIGNS.
Other Precautions: RPTS HAVE SHOWN THAT ASSOC RPTD & PRLNGD OCCUP OVEREXP
TO SOLVENTS CAN CAUSE PERM BRAIN & NERV SYS DAMAGE. INTENTIONAL MISUSE BY
DELIB CONC & INHALING CONTENTS MAY BE HARMFUL/FATAL. USE ONLY WITH ADEQ
UATE VENTILATION.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: 95.0F,35.0C
Lower Limits: 1.0%
Upper Limits: 8.0%
Extinguishing Media: WATER SPRAY, CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures: NIOSH APPRVD SCBA & FULL PROT EQUIP (FP N).
BLANKET FLAME W/ONE OF ABOVE EXTING MEDIA. VAPS OF COMBUST MAY BE IRRITATING
TO RESP TRACT. MAY CAUSE BRTHG (SUPDAT)
Unusual Fire/Explosion Hazard: KEEP MATERIAL AWAY FROM HEAT, SPARKS, AND OPEN
FLAMES.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH APPRVD DUST/MIST RESP (HIGH EFFICIENTY CARTRIDGE
ADVISED) IF SPRAYING/SANDING. USE ORG VAP CARTRIDGE RESP IF TLV FOR SOLV
COMPONENTS MAY BE EXCEEDED E.G. 8540 3M COPR RESP, (NIOSH APPRVD). WHEN
USING IN CONFINED AREA,
Ventilation: USE LOC EXHAUST WHEN APPLYING THIS PAINT IN CONFINED AREAS. KEEP
VAPORS BELOW TLV.
Other Protective Equipment: ANSI APRPVD EYE WASH & DELUGE SHOWER (FP N). USE
PROT CLTHG & CHANGE CONTAMD CLTHG IMMED.
Work Hygienic Practices: TRAIN EMPLOYEES ON ALL SPECIAL HANDLING PROCEDURES
BEFORE THEY WORK WITH THIS PRODUCT.
Supplemental Safety and Health: USERS OF "L" VERSION OF SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). APPEAR/ODOR: VAPOR, DUST, OR MIST). ODOR IS
NOT AN ADEQUATE WARNING OF INTOXICATION. FIRE FIGHT PROC: DFCLTYS. PVNT HUMA
N EXPOS TO FIRE, SMOKE, FUMES, ETC. HAZDECOMP PROD: & CO, HYDROGEN
CHLORIDE, & OTHER ORGANIC COMPOUNDS.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 245F,118C
Vapor Pres: 32 @ 100F
Vapor Density: 3.8
Spec Gravity: 1.35
VOC Grams/Liter: 380
Evaporation Rate & Reference: 1.17 (BUTYL ACETATE =1)
Solubility in Water: FAIR
Appearance and Odor: HOW TO DETECT THIS SUBSTANCE: (WARNING PROPERTIES OF
SUBSTANCE AS A GAS (SUPDAT
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEAT, SPARKS & OPEN FLAMES. DO NOT ALLOW VAPORS
TO ACCUMULATE.
Materials To Avoid: STRONG OXIDIZING MATERIALS, ACIDS, ALKALIS, AMINES AND
CHLORINATED HYDROCARBONS IN PRESENCE OF ALKALIS.
Hazardous Decomposition Products: (INCL COMBUST PROD): FLAMM FUMES MAY ACCUM IN
CONFINED AREA & SPKS/OPEN FLAMES MAY IGNITE IT. MAY LIBERATE CO*2 (SUPDAT)
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: VOLATILE ORGANIC COMPOUND: 380 GR/LTR
=======================================================
HAZCOM Label
=======================================================
Product ID: 1300 HIGH TEMPERATURE COATING
Cage: 9D157
Company Name: PRO-LINE PAINT CO
Street: 2646 MAIN STREET
Zipcode: 92113-3697
Label Required IND: Y
Date Of Label Review: 05/01/1998
Status Code: C
Label Date: 05/01/1998
Origination
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE. ACUTE: INHAL: VAPORS AND MIST IRRITATE NOSE
AND THROAT. HIGHER CONCENTRATIONS MAY CAUSE HEADACHE, NAUSEA, VOMITING,
KIDNEY AND LIVER DAMAGE AND COMA. SKIN/EYES: BURNING SENSATION FROM VAPOR
/LIQUID. DERMATITIS. LIQUIDS AND MISTS MAY SEVERELY IRRITATE OR DAMAGE EYES.
INGESTION: TOXIC. CAN CAUSE BURNING SENSATION, VOMITING, DIARRHEA, DROWSINESS
AND PERHAPS UNCONSCIOUSNESS. CHRONIC: CANCERHAZARD. CONTAINS VINYL ACETATE
WHICH IS LISTED AS AN ANIMAL LUNG CARCINOGEN (FPN). CAN CAUSE LIVER AND
KIDNEY DAMAGE. REPORTS HAVE ASSOCIATED REPEATED AND PROLONGED OCCUP OVEREXPOS
TO SOLVS W/PERMANEN T BRAIN AND NERVOUS SYSTEM DAMAGE. SENSITIZATION.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS & STEEL COMPOSITION
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DEVRAN 229 WHTE NON-EXEMPT BASE,MD4371,PT A
CAGE:EO141
CAGE:1HK86
CAGE:EO141
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 30%
Other REC Limits:N/K
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:N-BUTYL ALCOHOL (SARA III)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: <5%
Other REC Limits:N/K
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-ETHOXYETHYL ACETATE (CELLOSOLVE ACETATE) (EGEEA)
CAS:111-15-9
RTECS #:KK8225000
Fraction by Wt: 15%
Other REC Limits:N/K
OSHA PEL:S,100 PPM
ACGIH TLV:S, 5 PPM; 9192
Ingred Name:METHYL N-AMYL KETONE
CAS:110-43-0
RTECS #:MJ5075000
Fraction by Wt: <5%
Other REC Limits:N/K
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9192
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: <5%
Other REC Limits:N/K
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACRYLIC RESIN
Fraction by Wt: 5%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACRYLIC RESIN.VP:4.4 MMHG.
Fraction by Wt: 10%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:EPOXY RESIN
Fraction by Wt: 10%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:HIGH FLASH NAPHTHA.VP:3 MMHG.
Fraction by Wt: 15%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:UNKNOWN Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NIOSH STUDIES INDICATE 2-ETHOXYETHYL
ACETATE HAS CAUSED REPRO DISORDERS IN LAB ANIM (RATS/MICE) & HAS
POTENTIAL TO DO SAME IN HUM .REPORTS HAVE ASSOC RPTD & PRLNG
OVEREXPOS TO SOLV W/ PERM BRAIN & NERV SYS DMG.PRLNG OR RPTD BRTHG
OF MIST/DUST OVER YEARS MAY CAUSE DUST DISEASE OF LUNGS.EXTREME
EXPOS (SEE SUPP DAT)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:IRRIT.SKIN:IRRIT.HARMFUL IF
ABSORBED.INGEST:POSS STOMACH &/OR INTESTINAL IRRIT,NAUS,VOMIT &
DIAR.MAY BE HARMFUL OR FATAL.INHAL:RESP TRACT
IRRIT,HDCH,NAUS,DIZZ,WEAKNESS & FATIGUE.EXTREME EXPOS CAN RESULT
IN UNCONSCIOUSNESS & EVEN RESPIRATORY ARREST.OVEREXPOSURE MAY CAUSE
BLOOD DISORDERS.
Medical Cond Aggravated by Exposure:NONE,WHEN USED IN ACCORDANCE WITH
SAFE HANDLING AND USE INFORMATION.
======================= First Aid Measures =======================
First Aid:EYES:IMMED FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MIN.GET MED ASSISTANCE.SKIN:N/K .INGESTION:CALL MD IMMEDIATELY
.INHALATION:IF DIFFICULTY BREATHING,LEAVE AREA TO OBTAIN FR ESH
AIR.IF DIFFICULTY CONTINUES,GET MEDICAL HELP INMMEDIATELY.IF
BREATHING CEASES,RESTORE WITH APPROVED CPR TECHNIQUES AND SUMMON
MEDICAL HELP IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:80F,26.7C
Lower Limits:N/K
Upper Limits:0.7%
Extinguishing Media:CO*2,DRY CHEM,FOAM OR OTHER NFPA APPRVD METHOD FOR
TREATING A CLASS B FIRE.WATER SPRAY MAY BE INEFTIVE,FOG NOZZLE
PREF.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
.CALL PROFESSIONAL FIREFIGHTERS.ISOLATE CONTRS FROM HEAT,ELEC
EQUIP,SPARKS,FLAME-IF EXPOSED,COOL (SEE SUPP)
Unusual Fire/Explosion Hazard:VAP MAY CAUSE FLASH FIRE,IGNITE
EXPLO,SPREAD LONG DISTANCE & BEYOND CLSD DOORS.DUE TO PRESS
BUILD-UP,CLSD CONTRS MAY EXPLODE IF EXPOS TO EXTREME HEAT.(SEE
SUPP)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNIT SOURCES (FLAMES,HOT
SURFACES,& ELEC,STATIC,FRICTIONAL SPARKS).PVNT BRTHG OF VAP.VENT
AREA.BEFORE CLEAN-UP,REFER TO HAZ CAUTION INFORMATION.CONTAIN SPILL
& REMOVE W/ INERT ABSORB & NON -SPARKING TOOLS.STORE IN CLSD CONTR
UNTIL DISP.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F,49C OR NEAR
FIRE OR OPEN FLAME.STORE LARGE QUANTITIES IN BUILDINGS DESIGNED TO
COMPLY WITH OSHA.CLOSE CONTAINERS AFTER USE.
Other Precautions:DO NOT REUSE EMPTY CONTAINERS.DO NOT SMOKE.THIS
MATERIAL IS PART OF A TWO COMPONENT PRODUCT,THE MIXTURE OF BASE AND
CONVERTER PORTIONS WILL HAVE HAZARDS OF BOTH COMPONENTS.OBSERVE ALL
APPLICABLE PRECA UTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL & GENERAL VENT NEC TO KEEP AIR CONC BELOW TLV .PVNT
SOLV VAP BUILD-UP.ELIMINATE IGNITION SOURCES.
Other Protective Equipment:SOLVENT IMPERMEABLE CLOTHING AND BOOTS TO
PREVENT SKIN CONTACT.
Work Hygienic Practices:REMOVE & WASH SOILED CLOTHING BEFORE REUSE.WASH
HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health
FIRE FIGHT PROC:CONTR W/ WATER TO PVNT PRESS BUILDUP OR POSS
AUTOIGNIT.EXPLO HAZ:NEVER USE WELDING OR CUTTING TORCH ON OR NEAR
CONTR (EVEN EMPTY)-PROD/RESIDUE MAY IGNITE.HEAT DECOMP PROD:HAZ
FUMES OF CO,CO*2.HLTH HAZ:CAN CAUSE RESP ARREST.INTENTIONAL MISUSE
BY DELIB CONC & INHAL MAY BE HARMFUL/FATAL.INGEST:POSS FATAL.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:240-315F
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/K
Vapor Density:>1 (AIR=1)
Spec Gravity:1.27 (WATER=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:N/K
Appearance and Odor:WHITE LIQUID.
Percent Volatiles by Volume:56.34
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:N/K
Hazardous Decomposition Products:MAY CAUSE HAZARDOUS FUMES WHEN HEATED
TO DECOMPOSITION.FUMES MAY CONTAIN CARBON MONOXIDE,CARBON DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .INCINERATE ONLY IN APPROVED
FACILITY.DO NOT INCINERATE CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:87-9542, PETROLEUM ETHER
CAGE:59896
Contract Num:MDA414-01-P-0084
CAGE:59896
============= Composition/Information on Ingredients =============
Ingred Name:LIGROINE
CAS:8032-32-4
RTECS #:OI6180000
Minumum % Wt:90.
Maxumum % Wt:100.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:300 PPM
OSHA STEL:400 PPM
ACGIH TLV:300 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:LC50 (INH, RAT): 3,400 PPM/4H
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: LUNGS, CENTRAL NERVOUS
SYSTEM, KIDNEYS. ACUTE: EYES:MAY CAUSE IRRITATION. SKIN: MAY CAUSE
IRRITATION. INHALATION: MAY CAUSE IRRITATION TO RESPIRATORY TRACT.
INGESTION: MAY CAUSE GASTROI NTESTINAL DISCOMFORT.
Explanation of Carcinogenicity:NOT LISTED AS CAUSING CANCER BY NTP,
IARC, OR OSHA.
Effects of Overexposure:IRRITATING TO EYES AND SKIN. MAY CAUSE
DIZZINESS, NAUSEA, RESPIRATORY AND CARDIAC EFFECTS, GI SYSTEM
DISCOMFORT.
Medical Cond Aggravated by Exposure:NO INFORMATION AVAILABLE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES. HOLD EYELIDS OPEN. GET
MEDICAL ATTENTION IF IRRITATION PERSISTS. SKIN: REMOVE CONTAMINATED
CLOTHING; LAUNDER BEFORE REUSE. WASH EXPOSED SKIN AREA FOR AT LEAST
15MINUTES. GET MEDICAL ATTENTION IF IRRITATION PERSISTS.
INHALATION: MOVE TO FRESH AIR. GIVE OXYGEN IF BREATHING IS
DIFFICULT. GIVE ARTIFICIAL RESPIRATION IF BREATHING HAS STOPPED.
GET MEDICAL ATTENTIO N. INGESTION: IF CONSCIOUS, GIVE PLENTY OF
WATER AND INDUCE VOMITING IMMEDIATELY AS DIRECTED BY MEDICAL
PERSONNEL. CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY.
NEVER GIVE ANYTHING BY MOUTH T O AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:=-40.C, -40.F
Extinguishing Media:USE DRY CHEMICAL,C02, OR APPROPRIATE FOAM.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR FULL PROTECTIVE
EQUIPMENT AND NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:HIGHLY FLAMMABLE, CONFINED MATERIAL CAN
EXPLODE ON HEATING.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. ELIMINATE ALL SOURCES OF
IGNITION. REMOVE ALL NON-ESSENTIAL PERSONNEL FROM AREA. CLEAN-UP
PERSONNEL SHOULD WEAR PROPER PROTECTIVE EQUIPMENT AND CLOTHING.
ABSORB MATERIAL WITH SUITABLE ABSORBENT AND CONTAINERIZE FOR
DISPOSAL.
Neutralizing Agent:NOT PROVIDED
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN A COOL AREA AWAY FROM IGNITION SOURCES AND OXIDIZERS.
Other Precautions:AVOID BREATHING VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH/MSHA CHEMICAL CARTRIDGE RESPIRATOR
SHOULD BE WORN IF PEL OR TLV IS EXCEEDED.
Ventilation:MECHANICAL (GENERAL) VENTILATION IS RECOMMENDED. ALSO USE
LOCAL EXHAUST VENTILATION.
ALL TIMES.
Other Protective Equipment:LAB COAT, EYE WASH STATION, AND SAFETY
SHOWERS.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:>20.C, 68.F
B.P. Text:20-40C
Vapor Density:2.5
Spec Gravity:0.63
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR, COLORLESS, LIQUID; GASOLINE-LIKE ODOR.
Percent Volatiles by Volume:90-100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:VAPOR CONTACT WITH SPARK, FLAME, OR HOT
SURFACE.
Hazardous Decomposition Products:CARBON MONOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:INH-RAT LC50: 3,400 PPM/4H.N-PENTANE: INV-MUS
LD50: 446 MG/KG. NOT LISTED AS CAUSING CANCER BY NTP, IARC, OR
OSHA. TARGET ORGANS: LUNGS, CENTRAL NERVOUS SYSTEM , AND KIDNEYS.
PRIMARY ROUTES OF ENTRY: INHALATION, INGESTION.
===================== Ecological Information =====================
Ecological:EPA WASTE NUMBER: D001.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. ALWAYS CONTACT A PERMITTED WASTE DISPOSER
(TSD) TO ASSURE COMPLIANCE.
=================== MSDS Transport Information ===================
Transport Information:SHIPPING NAME: PETROLEUM DISTILLATES, N.O.S.,
CLASS 3, UN1268, PG I.
===================== Regulatory Information =====================
SARA Title III Information:HAZARD CATEGORY FOR SARA SECTION 311/312
REPORTING: ACUTE. SARA 313: SARA EHS SEC.302, TPQ; PETROLEUM ETHER,
NO. CHEMICALS NAME LIST: PETROLEUM ETHER, NO. CHEMICAL CATEGORY:
PETROLEUM ETHER, NO. CERCL A SEC. 103, RQ LBS: PETROLEUM ETHER, NO.
RCRA SEC. 261.33: PETROLEUM ETHER, NO.
Federal Regulatory Information:EPA TSCA STATUS: ON TSCA INVENTORY.
State Regulatory Information:NOT PROVIDED
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EA 9330 PART A
CAGE:1JB33
CAGE:1JB33
CAGE:33564
============= Composition/Information on Ingredients =============
Ingred Name:EPOXY RESIN
CAS:6508-38-6
Ingred Name:SILICA, AMORPHOUS, DUST
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: <0.5%
Other REC Limits:3 MG/CUM RESP. DUST
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3; 8990
Ingred Name:ALPHA-ALUMINA (ALUMINUM OXIDE) (EPA LISTS ONLY FIBROUS
FORMS) (SARA III)
CAS:1344-28-1
RTECS #:BD1200000
Fraction by Wt: <0.5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE/SKIN: CAUSE IRRITATION AS ALLERGIC
DERMATITIS
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYE/SKIN: CAUSE IRRITATION AS ALLERGIC
DERMATITIS.
Medical Cond Aggravated by Exposure:ALLERGIC DERMATITIS.
======================= First Aid Measures =======================
First Aid:IN CASE OF EYE CONTACT: FLUSH WITH PLENTY OF WATER FOR AT
LEAST 15 MINUTES. SKIN: WASH WITH SOAP & WATER. SEEK MEDICAL
ATTENTION IF IRRITATION PERSISTS. REMOVE CONTAMINATED
CLOTHING/THOROUGHLY CLEAN B EFORE REUSE.
================== Accidental Release Measures ==================
GLASSES. SCRAPE UP AND TRANSFER TO METAL CONTAINER. WIPE UP
REMAINING RESIDUE WITH SOLVENTS, OBSERVING SOLVENT FLAMMABILITY
CAUTIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP COOL IN ACCORDANCE W/LABEL
INSTRUCTIONS. WARNING CAUSE EYE/SKIN IRRITATION AS ALLERGIC
DERMATITIS. CONTAINS EPOXY RESINS. STORE AT TEMPS 70F.
Other Precautions:AVOID CONTACT W/EYES & SKIN. WASH THOROUGHLY AFTER
HANDLING. DON'T HANDLE OR USE UNTIL THE MSDS HAS BEEN
READ/UNDERSTOOD. FOLLOWED RECOMMENDED CURING SCHEDULE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NEEDED WITH GOOD INDUSTRIAL VENTILATION.
Ventilation:LOCAL EXHAUST RECOMMENDED
Other Protective Equipment:AS NEEDED TO PROTECT SKIN & CLOTHING
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING/THOROUGHLY CLEAN
BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:DECOMPOSES
Vapor Pres:>0.01
Vapor Density:NIL
Spec Gravity:>1
Evaporation Rate & Reference:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AS HAZARDOUS WASTE ACCORDING TO DOT
HAZARD CLASS. IF NOT REGULATED BY DOT, DISPOSE OF AS ORM-E.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DUAL SHIELD WIRES T115
CAGE:GO230
CAGE:GO230
CAGE:84021
============= Composition/Information on Ingredients =============
Ingred Name:CHROMIUM METAL, CHROMIUM, CHROME (SUSPECTED A1 HUMAN
CARCINOGEN BY IARC, NTP & ACGIH)
CAS:7440-47-3
RTECS #:GB4200000
OSHA PEL:1 MG/CUM (CEILING)
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:NICKEL (SOLUBLE) (SUSPECTED HUMAN CARCINOGEN BY NTP, IARC,
ACGIH) INTENDED CHANGE (IC)
CAS:7440-02-0
RTECS #:QR5950000
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/CUM
ACGIH TLV:0.05 MG/CUM IC
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
OSHA PEL:10 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:MANGANESE, MN COMPOUNDS
CAS:7439-96-5
RTECS #:OO9275000
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:CALCIUM FLUORIDE, FLUORSPAR, CALCIUM DIFLUORIDE, IRTRAN 3,
LIPARITE
CAS:7789-75-5
RTECS #:EW1760000
Other REC Limits:2.5 MG/CUM (AS F)
OSHA PEL:2.5 MG/CUM (AS F)
ACGIH TLV:2.5 MG/CUM (AS F)
Ingred Name:MOLYBDENUM (SOLUBLE COMPOUND), LEAD MOLYBDATE
CAS:7439-98-7
RTECS #:QA4680000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF NOSE, THROAT, EYES. MAY
LEAD TO SIDEROSIS WHICH MAY AFFECT PULMONARY FUNCTION. ARC RAYS CAN
INJURE EYES & BURN SKIN. ELECTRIC SHOCK CAN KILL. SEE SUPP.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:INHALATION: DIZZINESS, NAUSEA, IRRITATION OF
NOSE & THROAT. EYES: IRRITATION. SKIN: DRYNESS & BURNS.
Medical Cond Aggravated by Exposure:RESPIRATORY OR ALLERGIC CONDITIONS.
======================= First Aid Measures =======================
First Aid:EMPLOY FIRST AID TECHNIQUES RECOMMENDED BY THE AMERICAN RED
CROSS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Unusual Fire/Explosion Hazard:WELDING ARC & SPARKS CAN IGNITE
COMBUSTIBLES.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP HEAD OUT OF FUMES, DON'T TOUCH
LIVE ELECTRICAL PARTS, INSULATE FROM WORK & GROUND.
Other Precautions:TO DETERMINE COMPOSITION & QUANTITY OF FUMES & GASES
TO WHICH WORKERS ARE EXPOSED IS TO TAKE AN AIR SAMPLE INSIDE THE
WELDERS HELMET OR IN THE WORKER'S BREATHING ZONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRABLE FUME RESPIRATOR OR AIR SUPPLIED
RESPIRATORY WHEN WELDING IN CONFINED SPACE OR WHERE LOCAL EXHAUST
OR VENTILATION DOES NOT KEEP EXPOSURE BELOW TLV.
Ventilation:LOCAL EXHAUST AT THE ARC TO KEEP THE FUMES & GASES BELOW
THE TLV.
Other Protective Equipment:HELMET, ARM PROTECTORS, APRONS, HATS,
Supplemental Safety and Health
THE PRODUCT AS SUPPLIED IS NON-HAZARDOUS. HEALTH HAZARDS OCCUR DURING
OPERATIONS. THE COMPOSTION & QUANTITY OF WELDING FUMES ARE
DEPENDENT ON THE PROCESS, PROCEDURES, MEDIA, CONTAMINENTS IN THE
ATMOSP HERE, & ELECTRODES USED.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SEE SUPP
Stability Condition to Avoid:SEE SUPP
Hazardous Decomposition Products:CO, CO2, OZONE & NITROGEN OXIDES
FORMED BY THE RADIATION FROM ARC. WELDING FUMES - COMPLEX OXIDES
FROM THE INGREDIENTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSABLE CONTAINER OR
LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER, IN FULL COMPLIANCE
W/FEDERAL, STATE & LOC AL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
NIIN: 01-041-9869
Product ID: SPEARMINT SCENTAIRE SOLID
Cage: GO725
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 20200
Box: 6710
Cage: GO725
Cage: 0UXS5
=======================================================
Item Description Information
=======================================================
Item Manager: S9G
Item Name: DEODORANT,GENERAL PURPOSE
Specification Number: UNKNOWN
Unit of Issue: TU
Quantitative Expression: 00000000014OZ
UI Container Qty: 0
Type of Container: TUBE
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: MAY CAUSE STOMACH DISTRESS NAUSEA OR VOMITING IF
SWALLOWED.CHRONIC:NONE KNOWN.
Explanation Of Carcinogenicity: PER MSDS:CARCINOGENICITY:NTP/IARC/OSHA.
Signs And Symptions Of Overexposure: EYE IRRITATION, NAUSEA OR VOMITING.
Medical Cond Aggravated By Exposure: MEDICAL CONDITIONS AGGRAVATED BY OVEREXPO
TO THIS PRODUCT HAVE NOT BEEN ESTABLISHED.UNNECESSARY EXPOSURE SHOULD BE
AVOIDED.
First Aid: IF IRRITATION OR DISCOMFORT PERSISTS, CONTACT
PHYSICIAN.INHAL:NA.EYE:FLUSH IMMED W/PLENTY OF COOL RUNNING WATER.REMOVE
CONTACT LENSES.CONTINUE TO FLUSH EYES FOR 15MINS.SKIN:NA.INGEST:NEVER GIVE
ANYTHI NG BY MOUTH TO UNCONSCIOUS PERSON.DRINKWATER.DO NOT INDUCE
VOMITING.CONTACT PHYSICIAN.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: USE INERT ABSORBANT MATERIAL TO CLEANU SPILLS OR
LEAKS,SWEEP UP AND DISCARD IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
Handling And Storage Precautions: STORE IN COOL,DRY,VENTILATED AREA IN ORIGINAL
CLOSED CONTAINER OUT OF SUNLIGHT OR HEAT.STORE AT ROOM TEMPERATURE.
Other Precautions: FOLLOW STANDARD INDUSTRIAL HYGIENE PRACTICES.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: NA
Autoignition Temp Text: NA
Lower Limits: NA
Upper Limits: NA
Extinguishing Media: FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures: SELF-CONTAINED BREATHING APPARATUS AND PROTECTIVE
CLOTHING SHOULD BE WORN WHEN FIGHTING FIRES INVOLVING CHEMICALS.
Unusual Fire/Explosion Hazard: PRODUCT DOES NOT SUPPORT COMBUSTION.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE REQUIRED.
Ventilation: NONE REQUIRED.
Other Protective Equipment: NONE REQUIRED.
Work Hygienic Practices: STANDARD INDUSTRIAL HYGIENE PRACTICES.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
B.P. Text: 212F,100C
M.P/F.P Text: NA
Vapor Pres: NA
Vapor Density: NA
Spec Gravity: 1.010
Solubility in Water: 100%
Appearance and Odor: BLUE SOLID GEL, SPEARMINT ODOR
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: AVOID CONTACT WITH STRONG ACIDS, ALKALIS, AND/OR OXIDIZING
AGENTS.
Hazardous Decomposition Products: NONE KNOWN
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NA
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 102046
Product ID: SPEARMINT SCENTAIRE SOLID
Review Date: 08/28/1998
Net Unit Weight: 14 OZ
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: TU
Container QTY: 0
Type Of Container: TUBE
Additional Data: PER MSDS:DOT CLASS:NOT DOT REGULATED.
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: LABEL COVERED UNDER EPA REGS - HAZCOM LABEL NOT AUTHORIZED
=======================================================
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:OVER AND UNDER
CAGE:32204
CAGE:0U826
CAGE:32204
============= Composition/Information on Ingredients =============
Ingred Name:DIPROPYLENE GLYCOL METHYL ETHER (SARA III) (LD50: 5300
MG/KG [ORAL-RAT]; >2000 MG/KG [DERMAL-RABBIT])
CAS:34590-94-8
RTECS #:JM1575000
Minumum % Wt:1.
Maxumum % Wt:5.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
OSHA STEL:150 PPM
ACGIH TLV:100 PPM
ACGIH STEL:150 PPM
Ingred Name:DIETHYLENE GLYCOL ETHYL ETHER (SARA III)
CAS:111-90-0
RTECS #:KK8750000
Minumum % Wt:1.
Maxumum % Wt:5.
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Minumum % Wt:60.
Maxumum % Wt:100.
Other REC Limits:NONE RECOMMENDED
Ingred Name:ACRYLIC POLYMER (NON HAZARDOUS)
CAS:9011-15-8
RTECS #:1001265AP
Minumum % Wt:10.
Maxumum % Wt:30.
Other REC Limits:NONE RECOMMENDED
Ingred Name:TRIBUTOXYETHYL PHOSPHATE
CAS:78-51-3
RTECS #:KJ9800000
Minumum % Wt:1.
Maxumum % Wt:5.
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR 15 MINUTES.
REMOVE CONTACT LENSES. GET MEDICAL ATTENTION. SKIN: FLUSH WITH
COPIOUS AMOUNTS OF WATER. IF IRRITATION PERSISTS, SEE DR. INHAL:
NO SPECIAL REQ UIREMENTS. INGEST: NO SPECIAL REQUIREMENTS.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:NORMAL FIRE FIGHTING PROCEDURES MAY BE USED.
Unusual Fire/Explosion Hazard:NO SPECIAL HAZARDS KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH OIL-DRI OR SIMILAR MATERIAL. SWEEP
OR SCRAPE UP AND CONTAINERIZE. DO NOT LET SPILLED LEAKING MATERIAL
ENTER WATER COURSES. MAY BE TOXIC TO AQUATIC LIFE.
======================Handling and Storage ======================
Handling and Storage Precautions:CAUTION: AVOID CONTACT WITH SKIN,
EYES, AND CLOTHING. KEEP OUT OF REACH OF CHILDREN. FOR INDUSTRIAL
USE ONLY.
Other Precautions:STORE IN A COOL, DRY PLACE WITH ADEQUATE VENTILATION.
WASH THOROUGHLY AFTER HANDLING. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL REQUIREMENTS UNDER NORMAL USE
CONDITIONS.
Ventilation:GENERAL ROOM VENTILATION ADEQUATE.
Other Protective Equipment:NO SPECIAL REQUIREMENTS
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:1.03
pH:9.0-9.6
Solubility in Water:COMPLETE
Appearance and Odor:OPAQUE WHITE LIQUID, MILD AMMONIA-LIKE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NO SPECIAL REQUIREMENTS
Hazardous Decomposition Products:WHEN EXPOSED TO FIRE, PRODUCES NORMAL
PRODUCTS OF COMBUSTION
=================== Toxicological Information===================
Toxicological Information:WHOLE PRODUCT LD50: ACUTE ORAL TOX EST >5000
MG/KG RATS. DIPROPRYLENE GLYCOL METHYL ETHER LD50: >5300 MG/KG ORAL
RAT, >2000 MG/KG DERMAL RABBIT; LC50: >200 MG/L 1 HOUR.
TRIBUTOXYETHYL PHOSPATE LD50: >3000MG/KG ORAL RAT, >5000 MG/KG
DERMAL RABBIT. DIETHYLENE GLYCOL ETHYL ETHER LD50: 5540 MG/KG ORAL
RAT, 4000 MG/KG DERMAL RABBIT.
==================== Disposal Considerations ====================
Waste Disposal Methods:NO SPECIAL METHOD. OBSERVE ALL APPLICABLE
FEDERAL,PROVINCIAL,STATE REGULATIONS & LOCAL/MUNICIPAL ORDINANCES.
===================== Regulatory Information =====================
SARA Title III Information:DIETHYLENE GLYCOL ETHYL ETHER
State Regulatory Information:DIETHYLENE GLYCOL ETHYL ETHER: SUBJECT TO
THE PA, NJ, AND MA HAZARDOUS SUBSTANCE LISTS
| 0 | gloves_not_mandatory |
=======================================================
Product ID: DRY FOG ALUMINUM, 947452 (X)
Cage: 85519
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 85519
Box: 600
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHAL:IRRIT OF RESP TRACT. PRLNG INHAL MAY LEAD TO FATG,
DROW, DIZZ &/OR LT HEAD, HDCH, INCOORD, NAUS, VOMIT, CNS DEPRESS, ANESTH
EFT/NARCOS. SKIN CONT:IRRIT. PRLNG/RPTD CONT CAN CAUSE DERM, DEFAT. EY E
CONT:IRRIT. PRLNG/RPTD CONT CAN CAUSEBLURRED VISION, REDNESS, TEARING, SEV
IRRIT. INGEST:AMTS (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:INGESTED INCIDENTAL TO CONSUMER
& INDUS HNDLG ARE NOT LIKELY TO CAUSE INJURY; HOWEVER, LGR AMTS MAY CAUSE
LUNG INFLAMM & DMG DUE TO ASPIR OF MATL INTO LUNGS. NOTICE:RPTS HAVE
ASSOC RPTD & PRL NG OCCUP OVEREXP TO SOLVS W/PERM BRAIN & NERV SYS
DMG. INTENTIONAL MISUSE BY DELIB CONC & INHAL CONTENTS MAY BE (SUPDAT)
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL:REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED
BREATHING. HAVE TRAINED PERSON GIVE OXYGEN IF NECESSARY. GET EMERGENCY
MEDICAL ATTENTION. SKIN:WASH OFF QUICKLY W/PLENTY OF WATER, THEN SOAP &
WA TER; REMOVE & WASH CONTAMINATED CLOTHING BEFORE REUSE. EYES:FLUSH
IMMEDIATELY W/LARGE AMTS OF WATER, ESP UNDER LIDS, FOR AT LST 15 MINS. OBTAIN
EMER MED TREATMENT. INGEST:OBTAIN MED TREATMENT IMMED.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION (FLAME, HOT SURFACES
& ELECTRICAL, STATIC SPARKS). VENTILATE AREA & AVOID BREATHING
VAPORS. CONTAIN & REMOVE W/INERT ABSORBENT MATERIAL USING NON-SPARKING
TOOLS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE I/A/W LOCAL, STATE & FEDERAL REGULATIONS.
AVOID DISCHARGE TO NATURAL WATERS.
Handling And Storage Precautions: DO NOT STORE IN SUN/>100F. STORE LG QTYS
IN BLDGS DESIGNED FOR STOR OF FLAMM/COMBUST LIQS. DO NOT TAKE INTERNALLY.
KEEP OUT OF REACH OF CHILDREN.
Other Precautions: DO NOT WELD/FLAME CUT W/OUT PROPER VENT TO INSURE AREA IS
FREE OF FLAMM VAPS. DO NOT CUT, PUNCTURE/WELD ON/NEAR CNTNR. ENTRANCE INTO
CLSD STOR TANKS - USE APPROP NIOSH APPRVD RESP/AIR LINE FOR POSS EX POS TO
SOLV/CHEM FUMES. RAGS/ (SUPDAT)
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: SCC
Flash Point Text: >42F,>6C
Lower Limits: SEE INGS
Extinguishing Media: DRY CHEMICAL OR FOAM.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). WATER MAY BE USED TO COOL & PROTECT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard: FLAMM LIQ-CLASS IB & IC. CLSD CNTNRS MAY
EXPLODE WHEN EXPOS TO EXTREME HEAT/FIRE. VAPS CAN FORM EXPLO MIXTS IN AIR AT
ELEVATED TEMPS. MAY DECOMP UNDER (SUPDAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW APPLICABLE
STANDARDS. NIOSH APPROVED CHEMICAL MECHANICAL FILTER RESPIRATOR DESIGNED TO
REMOVE A COMBINATION OF PARTICULATE & VAPORS (TC23C OR EQUIVALENT).
Ventilation: ALL APPLICATION AREAS SHOULD BE VENTILATED I/A/W OSHA REGULATION
29 CFR 1910 DURING USE & UNTIL AREA IS FREE OF VAPORS.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: WASH HANDS THOROUGHLY BEFORE EATING OR USING SANITARY
FACILITIES.
Supplemental Safety and Health: NOTE:USERS OF "L" VERSION SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). EXPLO HAZ:FIRE CNDTNS EMITTING IRRIT &/OR
TOX GASES. EFTS OF OVEREXP:HARMFUL/FATAL. OTHER PREC:WASTE CNTNG OIL BASED
PAINT/ VARNISH THAT PRESENT LG AIR-TO-OIL INTERFACE WILL OXIDIZE & MAY
IGNITE SPONT & SHOULD BE PLACED IN METAL CONTAINER.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >230F,>110C
Vapor Pres: SEE INGS
Spec Gravity: 0.89-1.51(FP N)
Evaporation Rate & Reference: SLOWER THAN ETHYL ETHER
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume: 50-75
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: ELEVATED TEMPERATURES. CONTACT W/OXIDIZING
AGENTS.
Materials To Avoid: OXIDIZERS, ACIDS, BASES, AMINES.
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: DRY FOG ALUMINUM, 947452 (X)
Cage: 85519
Company Name: M A BRUDER & SONS INC
Street: 600 REED RD
PO Box: 600
Zipcode: 19008
Label Required IND: Y
Date Of Label Review: 04/07/1997
Status Code: C
Label Date: 04/07/1997
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: EXTREMELY FLAMM. ACUTE:INHAL:IRRIT OF RESP TRACT.
PROLONGED INHAL MAY LEAD TO FATIGUE, DROWSINESS, DIZZINESS &/OR LT HEAD,
HEADACHE, INCOORD, NAUSEA, VOMITING, CNS DEPRESSION, ANESTHETIC EFFECT OR NAR
COSIS. SKIN CONT:IRRITATION. PROLONGED OR REPEATED CONTACT CAN CAUSE
DERMATITIS, DEFATTING. EYE CONT:IRRITATION. PROLONGED OR REPEATED CONTACT CAN
CAUSE BLURRED VISION, REDNESS, TEARING, SEVERE IRRIT. INGEST:LARGE AMOUNTS
MAY CAUSE LUNG INFLAMM & DAMAGE DUE TO ASPIR OF MATL INTOLUNGS.
CHRONIC:RPTS HAVE ASSOC RPTD & PRLNG OCCUP OVEREXP TO SOLVS W/PERM BRAIN
& NERV SYS DMG. INTENTIONAL MISUSE BY DEL IB CONC & INHALING CONTENTS
MAY BE HARMFUL/FATAL.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:180 5886,EKTAPRINT 2 DEVEL REPLNSHR, PART C
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred
Name:4-(N-ETHYL-N-2-METHANESULFONYLAMINOETHYL)-2-METHYLPHENYLENEDIA
MINE USQUISULFATE MONOYDRATE (DISSOCIATES TO H*2SO*4)
RTECS #:PB4310000
Fraction by Wt: 30.0%
Ingred Name:WATER; WT % NOT KNOWN
CAS:7732-18-5
RTECS #:ZC0110000
===================== Hazards Identification =====================
Effects of Overexposure:INHAL:SO*2 IRRIT. EYES:LIQUID OR SO*2 IRRIT.
SKIN:LIQ. MAY IRRIT. RPTD CONTC. SKN RX.
======================= First Aid Measures =======================
First Aid:INHAL:ROMOVE FROM EXPOSURE;EYES:LIQUID CONTACT,FLUSH
IMMED.WITH PLENTY OF WATER & GET DOCTOR. SKIN:FLUSH WITH PLENTY OF
WATER.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:DILUTE WITH COPIOUS AMTS. OF WATER; ABSORB
WITH APPROPRIATE MATERIAL;PLACE IN APPROVED CONTAINER
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:ROUTINE USE OF A NON-ALKALINE(ACID)TYPE HAND CLEANER
WILL HELP MINIMIZE THE POSSIBLILITY OF ALLERGIC SKIN RX.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL REQUIREMENTS
Ventilation:LOCAL AND MECHAINCAL RECOMMEDED
Other Protective Equipment:AS NECESSARY TO PREVENT SKIN CONTACT
Supplemental Safety and Health
KEY1;P01;ITEM IS 4 PARTS KIT;THE CAT #:180 5886 REPLACES OLD CAT #121
6225(SEE PNI A,B,C,D THIS NSN FOR OLD CAT # AND OLD FORMULATION);
THIS NSN WAS CNCLD & REPLACED BY 6750-01-079-9722 EFFEC 86213;TH E
CAT # CHANGE OCCURED 6/79;THIS ENTRY DESCRIBES PART-C OF NEW CAT #;
SEE PNI A,B,D THIS NSN FOR OTHER PTS.KEY1:C1.
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:>212 F
Vapor Pres:17
Vapor Density:0.6
Spec Gravity:1.13
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR AMBER SOLUTION;SULFUR DIOXIDE ODOR
Percent Volatiles by Volume:62
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MINGRAL ACIDS AND STRONG ALKALIS
Hazardous Decomposition Products:SULFUR DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:OBSERVE FEDERAL,STATE AND LOCAL DISPOSAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DC-4056 BLACK TONER
CAGE:0AH08
CAGE:0AH08
CAGE:S4978
CAGE:65678
============= Composition/Information on Ingredients =============
Ingred Name:COLUMBIA CARBON, CARBON BLACK, LAMPBLACK, BLACK PEARLS
(IARC CARC GROUP 3) - *96-4*
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 5-10%
Other REC Limits:3.5 MG/CUM (NIOSH)
OSHA PEL:3.5 MG/CUM
ACGIH TLV:3.5 MG/CUM
Ingred Name:STYRENE, METHACRYLIC ACID, BUTYL METHACRYLATE, BUTYL
ACRYLATE POLYMER
CAS:58048-89-8
Fraction by Wt: 80-90%
Ingred Name:PROPENE POLYMERS, POLYPROPYLENE, POLYOLEFINE (SUSP CARC IA
RC GRP 3) *96-4*
CAS:9003-07-4
RTECS #:UD1842000
Fraction by Wt: 1-5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MINIMAL RESPIRATORY TRACT
IRRITATION MAY OCCUR.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & WATER. EYES: FLUSH THOROUGHLY W/WATER.
INGESTION: DILUTE STOMACH CONTENTS W/SEVERAL GLASSES OF WATER.
INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, WATER, FOAM/DRY CHEMICAL.
Fire Fighting Procedures:IF PRODUCT BECOMES INVOLVED IN A FIRE, USE
CO2.
Unusual Fire/Explosion Hazard:NONE UNDER NORMAL STORAGE & USE
CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP W/A VACUUM CLEANER.
======================Handling and Storage ======================
Handling and Storage Precautions:CLOSE CAP TIGHTLY & STORE IN A COOL,
DRY & DARK PLACE.
Other Precautions:AVOID COMBUSTION. AVOID INHALATION, INGESTION,
SKIN/EYE CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DUST FILTER RESPIRATOR RECOMMENDED WHEN HANDLING
BULK AMOUNTS.
Ventilation:NONE REQUIRED UNDER NORMAL USE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:280.4F
Spec Gravity:1.1
Solubility in Water:INSOLUBLE
Appearance and Odor:FINE BLACK POWDER; ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE IN NORMAL HANDLING & USE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DERMAPLUS
CAGE:ACUTE
CAGE:ACUTE
CAGE:0SC13
============= Composition/Information on Ingredients =============
Ingred Name:POLYVINYL PYRROLIDINONE- OF INSUFFICIENT VOLUME BY WEIGHT
TO REQUIRE DECLARATION
CAS:9003-39-8
RTECS #:TR8370000
Fraction by Wt: TRACE
Other REC Limits:NONE RECOMMENDED
Ingred Name:TRIETHANOLAMINE- OF INSUFFICIENT VOLUME BY WEIGHT TO
REQUIRE DECLARATION
CAS:102-71-6
RTECS #:KL9275000
Fraction by Wt: TRACE
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIMETHICONE
CAS:63148-62-9
Other REC Limits:NONE RECOMMENDED
Ingred Name:STEARIC ACID
CAS:57-11-4
RTECS #:WI2800000
Other REC Limits:NONE RECOMMENDED
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9293
Ingred Name:COCONUT ACID
CAS:61788-47-4
Other REC Limits:NONE RECOMMENDED
Ingred Name:ISOPROPYL MYRISTATE
CAS:110-27-0
RTECS #:XB8600000
Other REC Limits:NONE RECOMMENDED
Ingred Name:GLYCERIN
CAS:56-81-5
RTECS #:MA8050000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 (MIST) 9293
Ingred Name:TRIETHANOLAMINE
CAS:102-71-6
RTECS #:KL9275000
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYVINYL PYRROLIDINONE
CAS:9003-39-8
RTECS #:TR8370000
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: NONE IS CURRENTLY KNOWN. WHEN
PROPERLY USED AND APPLIED TO SKIN SURFACE AND ALLOWED TO DRY,
DERMAPLUS CANNOT BE TRANSMITTED OR TRANSFERRED TO ANYTHING WITHIN
ITS ENVIRONMENTAL PRESENCE.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:NONE
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:NORMALLY NON-IRRITATING. BATHE WITH WATER IF IRRITATION TO
EYES OCCURS. CANNOT BE INHALED UNLESS DILIBERATELY ATTEMPTED. SMALL
AMOUNTS COULD BE INGESTED WITHOUT UNDUE DISCOMFORT.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, HALON
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS. KEEP
CONTAINER FROM OPEN FLAME. PROVIDE PROTECTION AGAINST POSSIBLE
RUPTURE, BURSTING, OR VENTING.
Unusual Fire/Explosion Hazard:SHOULD THE TEMPERATURE EXCEED 130F THERE
MAY BE VENTING OF A SMALL AMOUNT OR PROPELLANT VAPOR, WHICH IS
FLAMMABLE IN AN OPEN FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH WITH WATER. COLLECT WITH ABSORBENT
MATERIAL, PLACE IN WASTE CONTAINER FOR TRANSFER TO LANDFILL
ACCORDING TO LOCAL, STATE AND FEDERAL REGUALTIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID STORING WHERE EXTREME
TEMPERATURES (>130F) WOULD EXIST. KEEP OUT OF REACH OF SMALL
CHILDREN. AVOID CRUSHING OR PIERCING.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:NONE NORMALLY REQUIRED.
Other Protective Equipment:NONE NORMALLY REQUIRED.
Work Hygienic Practices:OBSERVE NORMAL PRACTICES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V2
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:6724 MM HG
Vapor Density:>1(AIR=1)
Spec Gravity:0.94 (WATER=1)
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:APPRECIABLE
Appearance and Odor:WHITE FOAM OR MOUSSE (IN AEROSOL CAN); MILD
PLEASANT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:UNUSALLY ROUGH HANDLING.
Hazardous Decomposition Products:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE! PLACE IN WASTE CONTAINER FOR
DISPOSAL AT LANDFILL IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:QUICK COAT SPRAY ENAMELS SP-501 TOSP-528
CAGE:HO615
CAGE:55774
CAGE:HO615
============= Composition/Information on Ingredients =============
Ingred Name:PIGMENT
Fraction by Wt: 2.0%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VINYL TOLUENE SOYA ALKYD COPOLYMER
Fraction by Wt: 3.0%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MEDIUM OIL ALKYD
Fraction by Wt: 2.5%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:HYDROCARBON RESIN
Fraction by Wt: 3.5%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 5.2%
Other REC Limits:N/K
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ALIPHATIC HYDROCARBONS
CAS:64742-89-8
Fraction by Wt: 13.8%
Other REC Limits:500 PPM
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:METHYLENE CHLORIDE(SARA III)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 35.0%
Other REC Limits:500 PPM
OSHA PEL:500 PPM/C,1000; Z2
ACGIH TLV:50 PPM, A2; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PROPELLANT-ISOBUTANE AND PROPANE
CAS:68474-85-7
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BENZENE (SARA III)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: < 0.01%
Other REC Limits:N/K
OSHA PEL:1PPM/5STEL;1910.1028
ACGIH TLV:10 PPM; A2; 9192
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:SEE SIGNS AND SYMPTOMS OF OVEREXPOSURE
Explanation of Carcinogenicity:METHYLENE CHLORIDE: ACGIH-SUSPECTED
HUMAN CARC A2. BENZENE: ACGIH-SUSPECTED HUMAN CARC A2,NTP-KNOWN
HUMAN CARC(SUP DATA)
Effects of Overexposure:MAY BE HARMFUL OR FATAL IF SWALLOWED. EXCESSIVE
INHALATION OF VAPORS CAUSES HEADACHE, NAUSEA AND INCOORDINATION.
MAY BE IRRITATING TO EYES AND SKIN. THE TOXICOLOGICAL IMPACT OF
THIS PRODUCT HAVE NOT B EEN INVESTIGATED. REPEATED EXPOSURE
MAYPRESENT ADDITIONAL HAZARDS.
Medical Cond Aggravated by Exposure:N/K
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. IF NEEDED ADMINISTER ARTIFICIAL
RESPIRATION OR OXYGEN. CALL PHYSICIAN. INGEST: CALL PHYSICIAN, DO
NOT INDUCE VOMITING., ASPIRATION MAY LEAD TO PNEUMONITIS. SKIN:
WASH WITH SOAP AND WATER. EYE: FLUSH WITH PLENTY OF POTABLE WATER
FOR AT LEAST 15 MINUTES,THEN OBTAIN PROMPT MEDICAL ATTENTION
===================== Fire Fighting Measures =====================
Flash Point:19 F; -7.22 C
Lower Limits:N/K
Upper Limits:N/K
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:CAUTION: COMBUST LIQUID. BURN MAY PRODUCE
IRRIT HAZ PROD OF COMB INCLUDING FUMES, SMOKE, C*O2 AND/OR CO. SCBA
RECOM . AVOID SPREAD LIQUID + FLAME BY (SUP DATA)
Unusual Fire/Explosion Hazard:KEEP WORK + STORAGE AREAS FREE OF
IGNITION SOURCES. EXPOS TO EXCESSIVE HEAT + EXTREME TEMP BUILDS UP
PRESSURE IN CLOSED CONTR + MAY BURST OR EXPLODE.(SUP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION AND VENTILATEAREA.
COVER WITH INERT, ABSORBENT MATERIAL AND REMOVE TO DISPOSAL
CONTAINER. OBEY ALL RELEVANT FEDERAL, STATE, AND LOCALLAWS.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILD. CONBUST
LIQ.KEEP CONTR CLOSED WHEN NOT IN USE. KEEP AWAY FROM HEAT, SPARK +
OPEN FLAM. AVOID. BREATH VAPOR. (OTHER PREC)
Other Precautions:HNDLG/STOR PREC: USE W/ ADEQ VENT. AVOIDEYE CONT +
PRLNG/RPTD SKIN CONT. WASH AFTER HAND. NO SMOK IN AREA OF USE.
DON'T USE IN THE GEN VICIN OF ARC WELD, OPEN FLAME OR HOT SURFACE.
HEAT +/OR UV RAD MA Y CAUSE THE FORM OF HCL, OR COCL*2
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH?MSHA APPROVED MASK REQUIRED
(MFR).NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF
CONCERN .
Ventilation:LOCAL EXHAUST RECOMMENDED (MFR). CONSULTLOCAL SAFETY/HEALTH
AUTHORITIES IF ADDITIONAL GUIDANCE IS NECESSARY
Other Protective Equipment:N/K
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
FIRE FIGHT PROC: H*2O FLOOD. USE H*2O TOCOOL DOWN ADJACENT CONTAINERS
(MFR). WEAR PRESS DEMAND SCBA AND FULL PROT EQUIP . UNUSUAL FIRE +
EXPLO HAZ: THERMAL DECOMPOSITION PRODUCTS MAY INCLUDE HCL AND
PHOSGENE . EXPLAN OF CARCIN: OSHA-REG AS CARC. IARC-HUMAN CARC
(GROUP 1) . INGRED 9 FOR CA PROP 65 NOTE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:N/K
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/K
Vapor Density:HV THN AIR
Spec Gravity:N/K
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:N/K
Appearance and Odor:N/K
Percent Volatiles by Volume:89.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
N/K
Stability Condition to Avoid:N/K
Hazardous Decomposition Products:BURNING MAY CAUSE IRRITATING OR TOXIC
FUMES, CARBON MONOXIDE AND OR CARBON DIOXIDE (MFR). HCL, PHOSGENE
Conditions to Avoid Polymerization:WILL NOT OCCUR
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:THOMPSON'S WATERSEAL BRAND WATERPROOFING FORMULA
CAGE:THOMP
CAGE:THOMP
============= Composition/Information on Ingredients =============
Ingred Name:ALIPHATIC PETROLEUM DISTILLATE (MINERAL SPIRITS)
CAS:64742-88-7
Fraction by Wt: 85.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:VOC = 680 G/L LESS WATER
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: IRRIT, REDNESS, TEARING, BLURRED
VISION. SKIN: IRRIT, DEFATTING, DERMATITIS. INHAL: NASAL AND
RESPIRATORY IRRIT, DIZZY, WEAKNESS, FATIGUE, NAUSEA, HEADACHE,
UNCONSCIOUS, ASPHYXIATION. INGEST: GI IRRIT, NAUSEA, VOMIT,
DIARRHEA. ASPIRATION OF MATERIAL INTO LUNGS CAUSES CHEMICAL
PNEUMONITIS, FATAL.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/WATER, LIFTING LIDS. SKIN: WASH W/SOAP & WATER.
REMOVE CONTAM CLOTHES, WASH BEFORE REUSE. INHAL: REMOVE TO FRESH
AIR. OXYGEN OR ARTIFICIAL RESPIRATION IF NEEDED. KEEP WARM/QUIET.
INGEST: DONT INDUCE VOMIT. KEEP WARM/QUIET. IN ALL CASES, GET MED
AID.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>101F,>38C
Lower Limits:1.0
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE SCBA W/FULL FACE PIECE OPERATED IN
PRESSURE DEMAND MODE OR OTHER POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND MAY
TRAVEL TO IGNIT SOURCES.
================== Accidental Release Measures ==================
Spill Release Procedures:HANDLE AS COMBUSTIBLE LIQUID. ABSORB ON SAND,
CLAY OR OTHER ABSORBENT MATERIAL. ELIMINATE IGNIT SOURCES.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. STORE AWAY FROM
HIGH TEMPS & IGNIT SOURCES. USE ONLY W/ADEQUATE VENT. KEEP OUT OF
REACH OF CHILDREN.
Other Precautions:GROUND CONTAINERS WHEN POURING & LIMIT FREEFALL TO A
FEW INCES TO PREVENT STATIC SPARKS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV IS EXCEEDED, USE NIOSH/MSHA APPROVED
RESPIRATOR.
Ventilation:USE W/ADEQUATE VENT TO PREVENT EXCEEDING TLV.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:300 TO 430F
Vapor Pres:2.0
Vapor Density:4.9 AIR =1
Spec Gravity:.800 H20=1
Evaporation Rate & Reference:70.0 ETHYL ETHER=1
Appearance and Odor:COLORLESS LIQUID, W/PETROLEUM DISTILLATE ODOR.
Percent Volatiles by Volume:85%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXYGEN AND STRONG OXIDIZERS.
Stability Condition to Avoid:KEEP AWAY FROM IGNIT SOURCES.
Hazardous Decomposition Products:CARBON DIOXIDE AND CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE WASTE IN CLOSED CONTAINER. DISPOSE OF IN
ACCORDANCE W/LOCAL, STATE AND FEDERAL REGULATIONS GOVERNING
COMBUSTIBLE WASTE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:337 DUNCAN DOVE GRAY
CAGE:21546
CAGE:21546
============= Composition/Information on Ingredients =============
Ingred Name:DIACETONE ALCOHOL
CAS:123-42-2
RTECS #:SA9100000
Fraction by Wt: 0-5%
Other REC Limits:50 PPM
OSHA PEL:240 MG/CUM
ACGIH TLV:238 MG/CUM
Ingred Name:ISOBUTYL ACETATE
CAS:110-19-0
RTECS #:AI4025000
Fraction by Wt: 5-10%
Other REC Limits:150 PPM
OSHA PEL:150 PPM
ACGIH TLV:713 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-BUTANONE (METHYL ETHYL KETONE) (MEK)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 0-5%
Other REC Limits:590 MG/CUM
OSHA PEL:200 PPM
ACGIH TLV:590 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPYLENEGLYCOL MONOMETHYL ETHER ACETATE,
1-METHOXY-2-PROPANOL ACETATE
CAS:108-65-6
RTECS #:AI8925000
Fraction by Wt: 0-5%
Ingred Name:ETHYL ACETATE
CAS:141-78-6
RTECS #:AH5425000
Fraction by Wt: 0-5%
Other REC Limits:400 PPM
OSHA PEL:1400 MG/CUM
ACGIH TLV:1400 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETONE, DIMETHYL KETONE
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 40-45%
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: <19%
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: <19%
Other REC Limits:1000 PPM
OSHA PEL:1800 MG/CUM
ACGIH TLV:1000 PPM
Ingred Name:BUTANE, N-BUTANE
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: <19%
Other REC Limits:800 PPM
OSHA PEL:800 PPM
ACGIH TLV:1900 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NASAL & RESPIRATORY
IRRITATION/DIZZINESS/WEAKNESS/FATIGUE/NAUSEA/HEADACHE/UNCONSCIOUSNE
SS/ASPHYXIATION/PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE. EYES:
IRRITATION/REDNESS/TEARING/BLURRED VIS ION. INGESTION:
GASTROINTESTINAL IRRITATION/NAUSEA/VOMITING/DIARRHEA/CHEMICAL
PNEUMONITIS. SKIN: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: NASAL & RESPIRATORY
IRRITATION/DIZZINESS/WEAKNESS/FATIGUE/NAUSEA/HEADACHE/UNCONSCIOUSNE
SS/ASPHYXIATION/PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE. EYE:
IRRITATION/REDNESS/TEARING/BLURRED VISI ON. INGESTION:
GASTROINTESTINAL IRRITATION/NAUSEA/VOMITING/DIARRHEA/CHEMICAL
PNEUMONITIS. SKIN: IRRITATION.
Medical Cond Aggravated by Exposure:ALLERGIC RESPIRATORY & SKIN
REACTION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MINS. SKIN: WASH W/SOAP &
WATER. INHALATION: REMOVE TO FRESH AIR. IF NECESSARY, GIVE OXYGEN
OR CPR. INGESTION: DON'T INDUCE VOMITING. ASPIRATION OF MATERIAL
INTO LU NGS CAN CAUSE CHEMICAL PNEUMONITIS, WHICH CAN BE FATAL.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:0F
Lower Limits:1%
Extinguishing Media:ALCOHOL FOAM, CO2, OR DRY CHEMICAL
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. WATER MAY BE
USED TO COOL CLOSED CONTAINERS. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE. USE SCBA.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE OR
AUTOIGNITE WHEN EXPOSED TO EXTREME HEAT. VAPORS ARE >AIR & MAY
TRAVEL ALONG GROUND/MOVE BY VENTILATION.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. VENTILATE
AREA. ABSORB LIQUID ON ABSORBENT MATERIAL & TRANSFER TO A CLOSED
CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE >120F OR IN DIRECT
SUNLIGHT, HEAT, & OPEN FLAMES. DON'T PUNCTURE OR INCINERATE.
Other Precautions:AVOID INHALATION OF MISTS & VAPORS. DELIBERATELY
CONCENTRATING & INHALING THE CONTENTS MAY BE HARMFUL OR FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR (TC23C OR
EQUIVALENT).
Ventilation:LOCAL EXHAUST: RECOMMENDED. MECHANICAL (GENERAL):
RECOMMENDED WHEN SPRAYING.
Other Protective Equipment:AS NEEDED
Work Hygienic Practices:GOOD HYGIENE PRACTICES SHOULD BE FOLLOWED.
REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
EVAPORATION RATE FOR PROPELLANTS: (BU AC = 1): >1.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:133-331F
Melt/Freeze Pt:M.P/F.P Text: 1500F
Vapor Density:>1
Spec Gravity:<1
Evaporation Rate & Reference:(BU AC = 1): >1
Solubility in Water:SLIGHT TO MODERATE
Appearance and Odor:TYPICAL SOLVENT PAINT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXTREME HEAT, SPARKS, OPEN FLAME, DIRECT
SUNLIGHT, TEMPS >120F, & OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:TOXIC MATERIALS SUCH AS CO2, CO,
VARIOUS HYDROCARBONS, NITROGEN COMPOUNDS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. DON'T PUNCTURE OR INCINERATE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:190 0463,EA-5 FIRST DEVELOPER, PART C
Kit Part:Y
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:DIETHYLENE GLYCOL
CAS:111-46-6
RTECS #:ID5950000
Fraction by Wt: 80-85%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 15-20%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY CAUSE SKIN AND EYES
IRRITATION; CHRONIC: MAY DAMAGE KIDNEY.
Effects of Overexposure:INHALATION AND SKIN: LOW HAZARD FOR RECOMMENDED
HANDLING; INGEST:HARMFUL IF SWALLOWED. CAN CAUSE KIDNEY DAMAGE.
INGESTION OF LARGE AMOUNTS CAN CAUSE CENTRAL NERVOUS SYSTEM
DEPRESSION WITH SYMPTOMS INC LUDING DROWSINESS, HEADACHE, AND LOSS
OF CONSCIOUSNESS.
Medical Cond Aggravated by Exposure:NOT KNOWN TO KODAK.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES;
INGESTION:IF SWALLOWED AND CONSCIOUS,RINSE MOUTH & INDUCE VOMITING
IMMEDIATELY BY GIVING 1 OR 2 GLASSES OF WATER NEVER GIVE ANYTHING
BY MOUTH T O AN UNCONSCIOUS PERSON. CALL A PHYSICIAN OR POISON
CONTROL CENTER IMMEDIATELY; SKIN: WASH AFTER EACH CONTACT. GET
MEDICAL HELP IF SYMPTOMS OCCUR.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY;DRY CHEMICAL; CARBON DIOXIDE, 'ALCOHOL'
FOAM
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING TO PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:NONE NOTED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH MATERIAL TO SEWER WITH LARGE AMOUNTS OF
WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL CONTACT. KEEP
CONTAINERS TIGHTLY CLOSED
Other Precautions:KEEP FROM CONTACT WITH OXIDIZING MATERIALS; WARNING!
HARMFUL IF SWALLOWED.DO NOT BREATH VAPORS/MIST.AVOID CONTACT WITH
SKIN & CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY.
Ventilation:GOOD GENERAL VENTILATION RECOMMENDED.
Other Protective Equipment:NORMAL WORK CLOTHING COVERING ARMS & LEGS.
Work Hygienic Practices:GENERAL HYGIENE PRACTICE RECOMMENDED.
Supplemental Safety and Health
THIS IS PART-C OF THREE PART KIT. SOLUTION NUMBER OF THIS SOLUTION IS
3302.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:100C/212F
Vapor Pres:18MMHG@20C
Vapor Density:0.6
Spec Gravity:1.1
pH:2.0
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR SOLUTION.ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:NO INFORMATION FOUND
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCES CO &
CO*2
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW FEDERAL,STATE & LOCAL LAWS. THIS CHEMICAL
FORMULATION HAS A MODERATE BIOLOGICAL OXYGEN DEMAND & IT IS
EXPECTED TO CAUSE SOME OXYGEN DEPLETION IN AQUATIC SYSTEMS. IT IS
EXPECTED TO HAVE A HIGH P OTENTIAL TO AFFECT AQUATIC SYSTEMS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:N-6483A 2K RED PRIMER T-IIIF#156
Kit Part:Y
Preparer's Name:MICHAEL LICHATOWICH
CAGE:02388
CAGE:02388
============= Composition/Information on Ingredients =============
Ingred Name:EPOXY RESIN
CAS:25068-38-6
RTECS #:KC2100000
Fraction by Wt: 56%
Other REC Limits:NONE RECOMMENDED
Ingred Name:#100 SOLVENT
CAS:64742-95-6
Fraction by Wt: 20%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ALUMINIUM SILICATEKAOLIN
CAS:1332-58-7
RTECS #:GF1670500
Fraction by Wt: 15%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TALC (CONTAINING ASBESTOS)
CAS:14807-96-6
RTECS #:MW2700000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:RHEOLOGICAL ADDITIVE
Fraction by Wt: 1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION, LACRIMATION,
REDNESS, BLURRED VISION; SKIN: REDNESS/IRRITATION, DEFATTING,
LEADING TO DERMOTITIS INNHALE: NASAL/RESP IRRITATION, CNS
DEPRESSION, NAUSEA, HEADACHE, VERTIGO, UN CONSCIOUSNESS,
ASPHYXIATION; SWALLOWING: GI IRRITATION, ABDOMINAL PAIN, NAUSEA,
VOMITING, DIARRHEA.
Explanation of Carcinogenicity:NO
Effects of Overexposure:LIVER/KIDNEY/CNS/LUNG HAZZARDS. DUST MAY CAUSE
PNEUMOCONIOSIS AND PLURAL THICKENING
======================= First Aid Measures =======================
First Aid:INHALE: REMOVE TO FRESH AIR IMMED; GIVE CPR; GET MED AID
ASAP. SKIN: ** EYE: IMMED FLUSH WITH MUCH WATER AT LEAST 15 MINUTES
LIFTING UPPER/LOWER LIDS; GET MED AID IMMED; DO NOT WEAR CONTACT
LENSES WHI LE WORKING. INGEST: DRINK 1 OR 2 GLASSES OF WATER; DO
NOT INDUCE VOMITING; GET MED AID IMMED; TREAT SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:107F,38C
Lower Limits:1.9
Upper Limits:12.0
Extinguishing Media:DRY CHEMICAL, FOAM, CO2
Fire Fighting Procedures:WEAR SCUBA WITH FULL FACEPIECE IN POSITIVE
PRESSURE MODE; FULL PROTECTIVE CLOTHING; WATER MAY BE USED TO COOL
CONTAINERS TO PREVENT EXPLOSION.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED; ISOLATE
FROM ALL IGNITABLES; CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO
HEAT; EXPOSURE TO DECOMP PRODUCTS MAY CAUSE HAZARDS.*
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITABLES; MINIMIZE ALL CONTACT
WITH PRODUCT;DIKE; AVOID RUNOFF INTO SOIL, SEWERS, OR WATERWAYS.
ABSORB WITH INERT MATERIAL SUCH AS CLAY, SOIL, OR A COMMERCIALLY
AVAILABLE ABSORBENT; SH OVEL INTO SALVAGE DRUMS FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:AVLOID STORAGE IN HIGH TEMPERATURE
AREAS OR NEAR IGNITABLES; KEEP CONTAINERS CLOSED; AVOID ROUGH
HANDLING.
Other Precautions:EMPTY CONTAINERS MAY BE HAZARDOUS; DO NOT WELD/FLAME
CUT ON EMPTY DRUMS; SHOCK FROM DROPPING MAY SPLIT CONTAINER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR AN APPROPRIATE (TYPE TC-23C-75) PROPERLY
FITTED HALF-MASK OR FULL FACEPIECE RESPIRATOR (NIOSH/MSHA).
Ventilation:SUFFICIENT VENTILATION REQUIRED; REMOVE DECOMP PRODUCTS
FORMED DURING WELDING/FLAME CUTTING.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING.
Work Hygienic Practices:WASH IMMED UPON CONTAMINATION; REMOVE ANY WET
CLOTHING AND WASH BEFORE REUSE; WASH BEFORE EATING, SMOKING, USING
TOILET
Supplemental Safety and Health
VAPORS ARE HVR THAN AIR AND MAY TRAVEL ALONG GROUND TO AN IGNITION
SOURCE **SKIN: IMMED FLUSH W/MUCH WTR. IMMED REMOVE CONTAM
CLOTHING. FLUSH SKIN W/WTR. GET MED AID WASH CLOTHING AND
DECONTAM SHO ES BEFORE REUSE
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:242F,100C
Vapor Density:>AIR
Spec Gravity:1.216
VOC Grams/Liter:2.11
Viscosity:76-85 KU70-80
Evaporation Rate & Reference:<ETHER
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID, ODOR OF SOLVENTS
Percent Volatiles by Volume:29.16%
Corrosion Rate:MINIMAL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXYDIZERS
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:PER ALL LOCAL, STATE, AND FEDERAL REGULATIONS.
D001(IGNITABLE)
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SPEEDHIDE EXT LATEX WOOD PRIMER, 6-609
CAGE:47695
CAGE:47695
============= Composition/Information on Ingredients =============
Ingred Name:ZINC OXIDE. PEL: 10 MG/M3 TDUST; 5 MG/M3 RDUST
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: 1-2%
OSHA PEL:15MG/M3 TDUST/5 FUME
ACGIH TLV:10MG/M3 TDUST; 9293
Ingred Name:WATER (DEIONIZED)
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 40-45%
Ingred Name:PROPIONIC ACID, 2-METHYL-, MONOESTER
W/2,2,4-TRIMETHYL-1,3-PENTANEDIOL; (2,2,4-TRIMETHYL 1,3-PENTANEDIOL
ISOBUTYRATE)
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: 1-2%
Ingred Name:FILM FORMERS, RESINS & ADDITIVES
Fraction by Wt: 20-25%
Ingred Name:INGREDIENTS 9 & 10 ARE COMPONENTS OF ONE OR MORE OF THE
ABOVE INGREDIENTS
RTECS #:9999999ZZ
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE
CAS:14464-46-1
RTECS #:VV7325000
Fraction by Wt: 1-2%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.05 MG/M3 RDUST9293
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (QUARTZ)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 5-10%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:SUPP DATA: WHICH IARC ASSOC W/AN INCR RISK OF CANCER IN LAB
ANIMALS. LONG-TERM EXPOS TO CRYSTALLINE SILICA MAY (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:ALSO LEAD TO A DISABLING INJURY KNOWN AS SILICOSIS.
THESE EFTS ARE ASSOC W/BRTHG EXCESS AMTS OF SILICA (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:DUST. APPLICATN OF PROD IS NOT EXPECTED TO GENERATE
EXCESS AMTS OF RESPIRABLE SILICA, SO POTNTL HAZ FOR (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:HUMAN IS LIM. SIGNS & SYMPS: RED, ITCH, BURNING
SENSATION & VISUAL DISTURB MAY INDICATE EXCESS EYE CONT. (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:DRY, ITCH, CRACK, BURN, RED, & SWELL ARE CNDTNS
ASSOC W/EXCESS SKIN CONT.
RTECS #:9999999ZZ
Ingred Name:VENT: LEL BELOW STATED LIM, & TO REMOVE DECOMP PROD DURING
WELD/FLAME CUTTING ON SURF COATED W/PRODUCT.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: INGEST, EXCESSIVE EXPOS TO A CORR MATL,
PERSISTENT SKIN/EYE IRRIT/BRTHG DIFFICULTIES.
RTECS #:9999999ZZ
Ingred Name:SILICA, CRYSTALLINE-FUSED; (SILICA, AMORPHOUS-FUSED)
CAS:60676-86-0
RTECS #:VV7328000
Fraction by Wt: 1-2%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:DIATOMACEOUS EARTH, FLUX CALCINED; (SILICA,
AMORPHOUS-DIATOMACEOUS EARTH)
CAS:68855-54-9
Fraction by Wt: 15-20%
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 5-10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INGEST: HARMFUL/FATAL IF
SWALLOWED. EYE: CAUSES IRRIT. SKIN: MAY CAUSE SLIGHT IRRIT. INHAL:
VAP & SPRAY MIST MAY BE HARMFUL IF INHALED.VAP GENERATED @ ELEVATED
TEMPS IRRITATES EYES, NOSE & THRO AT. SAND & GRIND DUST MAY BE
HARMFUL IFINHALED. CHRONIC: AVOID LONG TERM & RPTD CONT. PROD CNTNS
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:CRYSTALLINE SILICA: GROUP 2A,IARC
MONOGRAPH, VOL 7, P.341, 1987; ANTICIPATED TO BE CARCIN, NTP 6TH
ANNUAL RPT,1991.
Effects of Overexposure:HLTH HAZ: TITANIUM DIOXIDE. ANIMALS INHALING
MASSIVE QTY OF TITANIUM DIOXIDE DUST IN A LONG-TERM STUDY DEVELOPED
LUNG TUMORS. STUDIES W/HUMANS INVOLVED IN MFR OF PIGMENT INDICATE
NO INCR RISK OF CANCE R FROM EXPOS. POTNTL FOR INHAL OF TITANIUM
DIOXIDE DUSTS FROM COATINGS IS VERY LIM. SINCE OVEREXP ARE NOT
(SUPP DATA)
======================= First Aid Measures =======================
First Aid:INGEST: DO NOT INDUCE VOMIT. EYE: FLUSH IMMED W/PLENTY OF
WATER FOR @ LST 15 MIN. SKIN: REMOVE PROMPTLY BY WIPING, FOLLOWED
BY WATERLESS HAND CLEANER & SOAP & WATER. INHAL: REMOVE TO FRESH
AIR. APPLYARTF RESP & OTHER SUPPORTIVE MEASURES AS REQD. OTHER:
IF ANY OF THE FOLLOWING OCCUR DURING/FOLLOWING USE OF PROD, CONT A
POIS CTL CTR, EMER ROOM/PHYS IMMED. HAVE MSDS SHEET INFO AVAIL.
(ING 17)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Extinguishing Media:USE NATL FIRE PROT ASSOC CLASS B EXTING (CARBON
DIOXIDE, DRY CHEM/UNIVERSAL AQUEOUS FILM FORM FOAM) DESIGNED (SUPP
DATA)
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
WATER SPRAY MAY BE INEFTIVE. WATER SPRAY MAY BE USED TO COOL CLSD
CONTRS TO PVNT PRESS BUILD UP & (SUPP DATA)
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE OR BURST
(DUE TO BUILD-UP OF STEAM PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:PROVIDE MAX VENT. ONLY PERS EQUIPPED W/PROPER
RESP & SKIN/EYE PROT SHOULD BE PERMITTED IN AREA. REMOVE ALL
SOURCES OF IGNIT. TAKE UP SPILLED MATL W/SAWDUST. VERMICULITE/OTHER
ABSORB MATL & PLACE INTO CONTAINERS FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. STORE LG QTY
IN BLDGS DESIGNED & PROTECTED FOR STORAGE OF NFPA CLASS IIIB
COMBUSTIBLE LIQUIDS. PROTECT FROM FREEZING.
Other Precautions:IF MATERIAL IS PART OF A MULTIPLE COMPONENT COATING
SYSTEM, READ MATERIAL SAFETY DATA SHEET(S) FOR THE OTHER COMPONENT
OR COMPONENTS BEFORE BLENDING AS RESULTING MIXTURE MAY HAVE HAZARDS
OF ALL OF ITS PARTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE VENTILATION IS INADEQUATE, USE A
NIOSH/MSHA APPROVED SUITABLE RESPIRATOR.
Ventilation:PROVIDE GEN DILUT/LOC EXHAUST VENT IN VOL & PATTERN TO KEEP
CONC OF INGRED BELOW LOWEST SUGGESTED EXPOS LIM, (ING 16)
Other Protective Equipment:PROTECTIVE CLOTHING CONSTRUCTED OF: NITRILE,
NEOPRENE OR LATEX.
Work Hygienic Practices:CLEAN OR DISCARD CONTAMINATED CLOTHING AND
SHOES.
Supplemental Safety and Health
EXTING MEDIA: TO EXTING NFPA CLASS IIIB COMBUST LIQ FIRES. FIRE FIGHT
PROC: POSS AUTOIGNIT/EXPLO WHEN EXPOSED TO EXTREME HEAT. IF WATER
IS USED, FOG NOZZ ARE PREF. HAZ DECOMP: CARBON MONOXIDE, ZINC OX
IDE. EFTS OF OVEREXP: EXPECTED, THERE IS NO SIGNIFICANT HAZ FOR
MAN. PROD CNTNS A FORM OF CRYSTALLINE SILICA (ING 11)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:100F,38C
Vapor Pres:17.2
Vapor Density:HVR/AIR
Spec Gravity:1.25
Evaporation Rate & Reference:33(BUTYL ACETATE=1)
Solubility in Water:48.8%
Appearance and Odor:VISCOUS LIQUID W/AN ODOR CHARACT OF CHEMICAL FAMILY
Percent Volatiles by Volume:80.40
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG ALKALIES, STRONG MINERAL ACIDS, OR STRONG
OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY PRDCE HAZ DECOMP PROD WHEN HEATED.
WELD, BRAZ/FLAME CUTTING ON SURF COATED W/PROD MAY PRDCE FUMES INCL
(SUPP DATA)
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MATL MUST BE DISPOSED OF I/A/W FED, ST,
PROVINCIAL, & LOC ENVIRONMENTAL CTL REGS. EMPTY CONTRS SHOULD BE
RECYCLED OR DISPOSED OF THROUGH AN APPROVED WASTE MANAGEMENT
FACILITY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:COMP B, MIL-P-53030, 44W007CAT
Kit Part:Y
Preparer's Name:MIKE SMITH
CAGE:5M511
CAGE:33461
CAGE:5M511
============= Composition/Information on Ingredients =============
Ingred Name:NITROETHANE (VAPOR PRESSURE 20.9 MM HG @ 77F)
CAS:79-24-3
RTECS #:KI5600000
Fraction by Wt: 15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:C8&10 AROMATIC HYDROCARBON (VAPOR PRESSURE 3 MM HG @ 68F)
CAS:64742-95-6
Fraction by Wt: <5%
Other REC Limits:MFR'S PEL: 100 PPM
Ingred Name:VOC: 219 G/L
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: RESP TRACT IRRIT
(HEADACHE,DIZZINESS,STAGGERING,CONFUSION,UNCONSCIOUSNESS,COMA).
SKIN: IRRIT (SWELLING,REDNESS,RASH).ABSORPTN: IRRIT
(DRYING,DEFATTING,SKIN CRACKING). EYES: IRRIT (TEARING,REDNE
SS,SWELLING W/STING). INGEST: IRRIT, CORROSIVE IN GI TRACT.VOMITING
MAY CAUSE ASPIRATION,RESULTING IN CHEM PNEUMONITIS.
Effects of Overexposure:ACUTE: VAPORS ARE IRRITATING TO EYES, NOSE, &
THROAT. INHALATION MAY CAUSE HEADACHES, DIFFICULT BREATHING &
UNCONSCIOUSNESS. CHRONIC: PROLONGED CONTACT WILL CAUSE DRYING AND
CRACKING OF THE SKIN, DUE TO DEFATTING ACTION. SKIN SENSITIZATION,
ASTHMA OR OTHER ALLERGIC RESPONSES MAY DEVELOP
Medical Cond Aggravated by Exposure:ASTHMA AND ANY OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA, AND DERMATITIS.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE TO FRESH AIR.RESTORE BREATHING.ASTHMATIC TYPE
SYMPTOMS MAY DEVELOP (IMMEDIATE/DELAYED BY SEVERAL HRS).GET MEDICAL
AID. SKIN:REMOVE CONTAMINATED CLOTHING.WASH AFFECTED AREAS W/SOAP &
WATER.W ASH CONTAMINATED CLOTHING BEFORE REUSE.EYES:FLUSH
W/LUKEWARM WATER (LOW PRESSURE) 15 MIN,LIFT EYELIDS.GET MED AID.
INGEST:DON'T INDUCE VOMITING.DON'T GIVE ANYTHING TO UNCONSCIOUS
PERSON.GET MED AID.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:87.0F,30.6C
Lower Limits:1.00
Upper Limits:0.00
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:WEAR FULL FIRE FIGHTING EQUIP W/SCBA & FULL
PROTECTIVE CLOTHING. USE WATER TO COOL CLOSED CONTAINERS TO PREVENT
PRESSURE BUILD-UP, AUTO IGNITION, OR EXPLOSION.
Unusual Fire/Explosion Hazard:KEEP CNTNR CLSD. KEEP FROM HEAT/IGNIT
SOURCE. CLSD CNTNR MAY EXPLODE W/HEAT. APPLIC TO HOT SURFACE REQ
SPECIAL PRECAUTION. OVEREXPOSURE TO DECOMP PROD-HLTH HZD.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE
ALL SOURCES OF IGNITION (FLAME, SPARK SOURCES, HOT SURFACES).
VENTILATE AREA. CONTAIN & REMOVE WITH INERT ABSORBENT AND
NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN BLDG IN COMPLY W/OSHA
1910.106,IN TIGHT CLOSD CNTNR IN VENTD AREA.AVOID STORING NEAR HIGH
TEMP/IGNIT SOURCE.PREVENT PROLONGED VAPOR BREATHING
Other Precautions:KEEP CONTAINERS TIGHT & UPRIGHT (PREVENT LEAK).
PROLONGED OVEREXPOSURE MAY CAUSE ALLERGIC REACTION. AVOID CONTACT
WITH SKIN & EYES. DO NOT INGEST. DO NOT HANDLE TILL MFR'S
PRECAUTIONS READ OR UNDERSTO OD. SMOKE IN SMOKING AREAS ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR RECOMMENDED FOR USE IN ORGANIC VAPOR
ENVIRONMENT (AIR PURIFYING/AIR SUPPLIED).OBEY OSHA REGS FOR
RESPIRATOR. VENT TO PROVIDE TO KEEP EXPOSURE LEVELS BELOW OSHA
LIMITS.
Ventilation:EXHAUST VENT TO KEEP AIRBORNE CONCENTRATION OF SOLVENT,
VAPORS & MISTS BELOW TLV. REMOVE IGNITION SOURCES.
Other Protective Equipment:THE USE OF LONG SLEEVE AND LONG LEG CLOTHING
IS RECOMMENDED. REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
WASHROOM.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:237 TO 335F
Vapor Density:> AIR
Spec Gravity:1.12845
Viscosity:*
Evaporation Rate & Reference:0.96 X N-BUTYL ACETATE
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER LIQUID WITH SOLVENT ODOR
Percent Volatiles by Volume:21.8
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS AND STRONG LEWIS OR MINERAL ACIDS.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, OR OPEN FLAMES.
AVOID UNCONTROLLED REACTIONS WITH AMINES.
Hazardous Decomposition Products:BY HIGH HEAT/TEMPERATURE: CARBON
MONOXIDE, CARBON DIOXIDE, AND OXIDES OF NITROGEN, ALDEHYDES & ACIDS
MAY BE FORMED.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MUST BE DISPOSED OF IN ACCORDANCE WITH
FEDERAL, STATE, & LOCAL ENVIRONMENTAL CONTROL REGULATIONS. EMPTY
CONTAINERS MUST BE HANDLED WITH CARE, DUE TO PRODUCT RESIDUE &
FLAMMABLE VAPOR. DO NOT INC INERATE CLOSED CONTAINERS. EPA HZD
CODE: D001.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ROYCO 363B
CAGE:07950
CAGE:07950
============= Composition/Information on Ingredients =============
Ingred Name:HYDROTREATED LIGHT NAPHTHENIC DISTILLATE PETROLEUM (TAKE
TLV AS OIL MIST=5MG/CUM)
CAS:64742-53-6
RTECS #:PY8036000
Fraction by Wt: >97%
ACGIH TLV:5MG/CUM(OILMIST
Ingred Name:UNIDENTIFIED COMPONENTS
Fraction by Wt: <3.0%
ACGIH TLV:NOT SPECIFIED
===================== Hazards Identification =====================
Effects of
Overexposure:EYES:IRRITATION;SKIN:IRRITATION,DERMATITIS;INHAL:IRRIT
ATION;INGEST:G.I.DISTURBANCES,DIARRHEA.
======================= First Aid Measures =======================
First Aid:INHALE:REMOVE TO FRESH AIR, GIVE CPR/O*2 IF
NEED;EYES/SKIN:FLUSH W LG AMTS H*2O FOR 15 MIN;INGEST:RINSE MOUTH;
GET MEDICAL ATTENTION FOR EYES, BREATHING DIFFICULTY, OR OTHER
SYMPTOMS OF OVEREXPOSURE.
===================== Fire Fighting Measures =====================
Flash Point:330F/166C (COC)
Extinguishing Media:CO*2,DRY CHEMICAL POWDER,FOAM.DO NOT USE WATER JET.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA WITH FULL
PROTECTION.
Unusual Fire/Explosion Hazard:NONE NOTED,USE REASONABLE
CARE,COMBUSTIBLE MATERIAL.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;USE INERT
ABSORBENT MATERIALS AND RECOVER FOR PROPER DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY PLACE WITH ADEQUATE
VENTILATION.KEEP AWAY FROM OPEN FLAMES AND HIGH TEMPERATURES.KEEP
CONTAINERS CLOSED WHEN NOT IN USE.
Other Precautions:AVOID CONTACT WITH SKIN AND EYES.DO NOT SMOKE,EAT OR
DRINK.WASH THOROUGHLY AFTER EACH USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR OIL
MIST/VAPORS IF ABOVE TLV.
Ventilation:MECH(GEN)OR LOCAL EXHAUST THAT PROVIDES ADEQUATE
VENTILATION
Other Protective Equipment:FULL WORK CLOTHING TO PREVENT REPEATED OR
PROLONGED CONTACT.
Supplemental Safety and Health
MSDS DATED NOVEMBER 1, 1985.
================== Physical/Chemical Properties ==================
HCC:V6
Spec Gravity:0.87
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TAN COLORED MILD BLAND PETROLEUM ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT,OPEN FLAMES.
Hazardous Decomposition Products:COMBUSTION:CO,CO*2,UNKNOWN ORGANIC
COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF COLLECTED MATERIAL IN ACCORDANCE WITH
LOCAL,STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MALONONITRILE, 99%, M140-7
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:MALONONITRILE
CAS:109-77-3
RTECS #:OO3150000
Fraction by Wt: 99%
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY BE FATAL IF INHALED,
SWALLOWED, OR ABSORBED THRU SKIN. VAPOR/MIST IS IRRITATING TO EYES,
MUCOUS MEMBRANES AND UPPER RESPIRATORY TRACT. CAUSES SKIN
IRRITATION. ABSORPTION INTO BODY LEADS TO THE FORMATION OF
METHEMOGLOBIN WHICH INSUFFICIENT CONCENTRATION CAUSES CYANOSIS.
ONSET MAY BE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: DELAYED 2-4 HOURS OR LONGER. TO THE
BEST OF MFR'S KNOWLEDGE, THE CHEMICAL, PHYSICAL, AND TOXICOLOGICAL
PROPERTIES HAVE NOT BEEN THOROUGHLY INVESTIGATED.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT
LEAST 15 MINUTES. SKIN: IMMEDIATELY FLUSH WITH SOAP AND COPIOUS
AMOUNTS OF WATER. WASH CONTAMINATED CLOTHING BEFORE REUSE. INHAL:
REMOVE TO FRESH AIR. IF NOT BREATHING GIVE ARTIFICIAL RESPIRATION.
IF BREATHING IS DIFFICULT, GIVE OXYGEN. INGEST: WASH OUT MOUTH
W/WATER PROVIDED PERSON IS CONSCIOUS. CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:234F,112C
Extinguishing Media:WATER SPRAY. CARBON DIOXIDE, DRY CHEMICAL POWDER OR
APPROPRIATE FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH/MSHA APPROVED SCBA, RUBBER BOOTS &
DISPOSAL. AVOID RAISING DUST. VENTILATE AREA AND WASH SPILL SITE
AFTER MATERIAL PICKUP IS COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT BREATHE VAPOR. DO NOT GET IN
EYES, ON SKIN/CLTHG. AVOID PRLNGD/RPTD EXPOSURE. HIGHLY TOXIC.
IRRITANT. KEEP TIGHTLY CLOSED.
Other Precautions:STORE IN A COOL DRY PLACE. IF YOU FEEL UNWELL, SEEK
MEDICAL ADVICE (SHOW THE LABEL WHERE POSSIBLE).
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:OTHER PROTECTIVE CLOTHING, SAFETY SHOWER AND
EYE BATH.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:428F,220C
Melt/Freeze Pt:M.P/F.P Text:89.6F,32C
Spec Gravity:1.049
Appearance and Odor:WHITE CRYSTALLINE SOLID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS, STRONG BASES, STRONG REDUCING
AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF CARBON MONOXIDE, CARBON
DIOXIDE, NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE/MIX MATERIAL WITH A COMBUSTIBLE SOLVENT
AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN AFTERBURNER &
SCRUBBER. DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:2150, SPECIAL SEMI-GLOSS WHITE
CAGE:11111
CAGE:11111
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA, MEDIUM ALIPHATIC; (ALIPHATIC SOLVENT NAPHTHA
(PETROLEUM) MINERAL SPIRITS). VP:10. LD50: (ORAL, RAT) >25 ML/KG.
CAS:64742-88-7
Fraction by Wt: 23-35%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE). LD50: (ORAL, RAT) >9500
MG/KG.
CAS:1317-80-2
RTECS #:XR2275000
Fraction by Wt: 0-35%
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 0-4%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:CALCIUM CARBONATE; (MARBLE), (LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 0-17%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS 1 & 2
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION OF HIGH VAPOR
CONCENTRATIONS MAY HAVE RESULTS RANGING FROM DIZZINESS, HEADACHES,
GIDDINESS, NAUSEA TO UNCONSCIOUSNESS. PROLONGED OR REPEATED LIQUID
CONTACT WITH SKIN WILL DRY AND DEFAT SKIN , LEADING TO IRRITATION
AND DERMATITIS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM EXPOSURE IMMEDIATELY; CALL MD. IF
BREATHING IS IRREGULAR OR STOPPED, START RESUSCITATION, ADMINISTER
O2. INGEST: DO NOT INDUCE VOMITING; CALL MD. IF VOMITING OCCURS,
KEEP HEAD BELOW HIPS TO KEEP LIQUID OUT OF LUNGS. SKIN: REMOVE ANY
CONTAMINATED CLOTHING, AND WASH SKIN WITH SOAP AND WARM WATER.
EYES: FLUSH WITH CLEAR WATER FOR AT LEAST 15 MINUTES OR UNTIL
IRRITATION SUBSIDES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:105F,41C
Lower Limits:1%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . DO NOT USE A DIRECT STREAM OF WATER. PRODUCT
WILL FLOAT AND CAN BE REIGNITED.
Unusual Fire/Explosion Hazard:CONTAINERS EXPOSED TO INTENSE HEAT FROM
FIRES SHOULD BE COOLED WITH WATER TO PREVENT VAPOR PRESSURE BUILDUP
WHICH COULD RESULT IN CONTAINER RUPTURE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNIT SOURCES.KEEP PEOPLE AWAY.
RECOVER FREE LIQ.ADD ABSORB (SAND, EARTH, SAWDUST, ETC) TO SPILL
AREA.AVOID BRTHG VAPS.VENT CONFINED SPACES.OPEN ALL WINDOWS &
DOORS. KEEP PETRO PRODS OUT OF SEWERS & WATERCOURSES, OR EXTENSIVE
LAND AREAS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE. DO NOT HANDLE OR STORE NEAR HEAT, SPARK, FLAME OR STRONG
OXIDANTS.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPRVD HYDROCARBON VAP CANNISTER
OR SUPPLIED-AIR RESP PROT IN CONFINED/ENCLOSED PLACES IF OCCUP
EXPOSURE LIMITS ARE EXCEEDED. USE A NIOSH/MSHA APPROVED DUST RESP
WHEN SANDING THESE PROD S IF OCCUP EXPOS LIMITS ARE EXCEEDED.
Ventilation:EXHAUST AT OVER 60 FPM.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:>310F,>154C
Vapor Pres:SEE ING 1
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:40-50
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS LIKE; LIQUID CHLORINE, CONCENTRATED OXYGEN, SODIUM OR
CALCIUM HYPOCHLORITE.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:FUMES, SMOKE AND CARBON MONOXIDE, IN
THE CASE OF INCOMPLETE COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:ASSURE CONFORMITY WITH APPLICABLE DISPOSAL
REGULATIONS. DISPOSE OF ABSORBED MATERIAL AT AN RCRA APPROVED
DISPOSAL SITE OR FACILITY. DISPOSE OF I/A/W FEDERAL, STATE AND
LOCAL REGULATIONS .
| 1 | gloves_mandatory |
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.