text
stringlengths 542
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:CS 3204,CLASS B-1/2,MIL-S-8802 D,PH A
CAGE:JO800
CAGE:JO800
CAGE:13422
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 4%.
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:LP-32 LIQUID POLYSULFIDE POLYMER (MFR THIOKOL CORPORATION,
CHEMICAL DIVISION)
===================== Hazards Identification =====================
Effects of Overexposure:AVOID EYE CONTACT OR PROLONGED SKIN CNTCT
======================= First Aid Measures =======================
First Aid:EYE: IMMEDIATELY FLUSH WITH WATER FOR 15 MIN. CALL MD IF
NECESSARY. SKIN: WASH THOROUGHLY WITH MILD SOAP AND WATER
===================== Fire Fighting Measures =====================
Flash Point:210 F CC
Lower Limits:7.
Upper Limits:90.
Extinguishing Media:STANDARD MEDIA, CO*2, ETC
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:MFG SUGGESTS NO PRECAUTIONS NECESSARY; SOLVENT
WIPE-TAKING PRECAUTIONS AGAINST FIRE AND INHALATION HAZARDS.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PROLONGED CONTACT.
============= Exposure Controls/Personal Protection =============
Ventilation:MECHANICAL-YES
Other Protective Equipment:NONE
Supplemental Safety and Health
PART A OF A TWO PART PRODUCT. MIX RATIO BY WEIGHT IS 100:10 (A:B)
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NA
Boiling Pt:B.P. Text:450F
Vapor Pres:2.
Vapor Density:3.1
Spec Gravity:1.42
Evaporation Rate & Reference:0.02
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OFF WHITE PASTE, POLYSULFIDE ODOR.
Percent Volatiles by Volume:4.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SULFURIC, NITRIC, & HYDROCHLORIC ACIDS.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:SANITARY LANDFILL IN ACCORDANCE W/LOCAL, STATE,
& FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SKIMMING PIG MATS #MAT212/214/215/224/402/414/420/442/443
CAGE:1JA49
CAGE:1JA49
============= Composition/Information on Ingredients =============
Ingred Name:POLYPROPYLENE
CAS:9003-07-0
Fraction by Wt: 99.7%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ZELEC-ANTI STATIC AGENT
Fraction by Wt: 0.3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NA
Effects of Overexposure:NA
Medical Cond Aggravated by Exposure:NA
======================= First Aid Measures =======================
First Aid:NA
===================== Fire Fighting Measures =====================
Flash Point:825F,441C
Autoignition Temp:Autoignition Temp Text:825F
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:IN PURCHASED/UNUSED FORM, WATER CHEMICAL FOAM, DRY
CHEMICAL, CO2. USED: FORM, THAT IS COMPATIBLE TO LIQUID ABSORBED
Fire Fighting Procedures:WEAR SCBA & REFER TO ABSORBED LIQUIDS.
Unusual Fire/Explosion Hazard:REFER TO ABSORBED LIQUIDS
================== Accidental Release Measures ==================
Spill Release Procedures:PURCHASED/UNUSED FORM: SWEEP/VACUUM PRODUCT &
DISPOSE OF AS NON-HAZARDOUS MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:NA
Other Precautions:REFER TO ABSORBED LIQUIDS. SKIMMING PIG MATS DON'T
RENDER LIQUIDS NONFLAMMABLE, NEUTRAL OR LESS HAZARDOUS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NA
Ventilation:NA
Other Protective Equipment:NA
Work Hygienic Practices:NA
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NA
Melt/Freeze Pt:M.P/F.P Text:320F,160C
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:0.9
Evaporation Rate & Reference:NA
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE SHEETS OR ROLLS, NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS MAY DEGRADE PRODUCT.
Stability Condition to Avoid:NA
Hazardous Decomposition Products:NA
==================== Disposal Considerations ====================
Waste Disposal Methods:IF IN PURCHASED OR UNUSED FORM, NO SPECIAL
PRECAUTIONS NECESSARY. IF USED FORM DISPOSE OF ALL WASTE BASED ON
COMPONENTS OF LIQUID ABSORBED ACCORDING TO FEDERAL, STATE, LOCAL
LAWS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:NATURAL GRAPHITE
CAGE:KO743
CAGE:84195
CAGE:KO743
============= Composition/Information on Ingredients =============
Ingred Name:SILICA (CRYSTALLINE-QUARTZ)
CAS:14808-60-7
RTECS #:VV7330000
Other REC Limits:N/K
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:GRAPHITE (NATURAL).ACGIH TLV FROM INTENDED CHANGE LIST
1990-91.
CAS:7782-42-5
RTECS #:MD9659600
Other REC Limits:N/K
OSHA PEL:15 MPPCF RDUST
ACGIH TLV:2 MG/M3 RDUST; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:CASES OF PULMONARY
FIBROSIS,EMPHYSEMA,AND CORPULMONALE MAY RESULT FROM PROLONGED
INHALATION OF DUST (CHRONIC).
Explanation of Carcinogenicity:CRYSTALLINE SILICA:LIMITED EVIDENCE FOR
CARCINOGENICITY IN HUMANS;SUFFICIENT EVIDENCE FOR CARCINOGENICITY
IN (SEE SUPP)
Effects of Overexposure:EYES/SKIN:REDNESS.INGESTION:N/K .INHALATION:N/K
.
Medical Cond Aggravated by Exposure:EMPHYSEMA,ASTHMA.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES .SKIN/INGESTION:N/K .INHALATION:REMOVE FROM DUST UNTIL
NORMAL AGAIN.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER
Fire Fighting Procedures:SPRAY WITH WATER.STANDARD TURNOUT GEAR WITH
NIOSH/MSHA APPROVED SCBA .
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP OR VACUUM UP.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE OSHA APPROVED RESPIRATOR FOR NUISANCE DUST.
Ventilation:LOCAL EXHAUST TO DUST COLLECTOR.
Other Protective Equipment:NONE
Work Hygienic Practices:KEEP WORK AREA CLEAN.
Supplemental Safety and Health
SPECIFIC GRAVITY:2.20-2.35 (WATER=1).EXPLANATION OF
CARCINOGENICITY:ANIMALS (IARC,1987).KNOWN TO CAUSE CANCER (CAL PROP
65,1988).WASTE DISPOSAL METHOD:OR LANDFILL.ROUTES OF ENTRY:SKIN
CONTACT (MFR).MA TERIAL IS A GOOD ELECTRICAL CONDUCTOR.
================== Physical/Chemical Properties ==================
HCC:N1
Decomp Temp:Decomp Text:N/K
Spec Gravity:SEE SUPP DATA
Solubility in Water:INSOLUBLE
Appearance and Odor:GREY TO BLACK WITH NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
N/K
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:N/K
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE,AND LOCAL REGULATIONS.COORDINATION WITH SUPPORTING
INSTALLATION AND/OR MACOM ENVIRONMENTAL COORDINATION PRIOR TO
DISPOSAL IS RECOMMENDED TO DETERMINE APPROPRIATE DISPOSAL METHODS
.BURN (SEE SUP)
| 0 |
gloves_not_mandatory
|
=======================================================
Product ID: WM WASH
Cage: LXTHC
=======================================================
Contractor Summary
=======================================================
Cage: LXTHC
=======================================================
Ingredients
=======================================================
Cas: 64742-88-7
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 108-88-3
RTECS #: XS5250000
OSHA PEL: 200 PPM
ACGIH TLV: 50 PPM, S
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 110-80-5
RTECS #: KK8050000
OSHA PEL: 200 PPM, S
ACGIH TLV: 5 PPM, S
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
RTECS #: 9999999VO
GM/LITER
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
APPROP HLTH PROFESSIONALS CONCERNING LATEST
-----------------------------
(FP N).
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHAL: VAPS MAY CAUSE IRRIT TO MUC MEMBS & RESP TRACT.
HIGH VAP CONCS MAY CAUSE CNS DEPRESS & CAUSE LIVER, KIDNEY & BLOOD
FORMING ORGAN DMG. SKIN/EYES: IRRIT TO SKIN & EYES. MAY BE ABSORB THRU
SKIN. S YMPS SIMILAR TO INHAL. INGEST: SYMPS ESSENTIALLY SAME AS ABSORP. MAY
CAUSE VOMIT.AVOID ASPIR OF VOMITUS(EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: INTO LUNGS AS EVEN SML AMTS MAY
CAUSE ASPIR PNEUM. SKIN ABSORB: KIDNEY DMG EVIDENCED BY CHANGES IN URINE
OUTPUT OR APPEARANCE. LIVER DMG EVIDENCED BY LOSS OF APPETITE OR JAUNDICE
& SOMETIMES PAIN IN UPPER RIGHT ABDOMEN. DMG TO BLOOD FORMING ORGANS MAY
BE EVIDENCED BY EASY FATIGABILITY & PALLOR.(SUPDAT)
Medical Cond Aggravated By Exposure: PREEXISTING EYE, SKIN, RESPIRATORY, LIVER,
KIDNEY, BLOOD-FORMING ORGAN FUNCTIONS MAY BE AGGRAVATED.
First Aid: EYE: FLUSH W/RUNNING WATER FOR AT LST 15 MINS WHILE HOLDING EYELIDS
OPEN. GET MED ATTN. SKIN: REMOVE CONTAMD CLTHG. WASH AFFECTED AREA W/SOAP
& WATER. SEEK MED ATTN IF IRRIT PERSISTS. INHAL: REMOVE VI CTIM TO FRESH
AIR & PROVIDE OXYGEN IF BRTHG IS DFCLT. GIVE ARTF RESP/CPR IF BRTHG
STOPS. GET MED ATTN. INGEST: DO NOT GIVE LIQS TO UNCON PERSON. OTHERWISE GIVE
2 GLASSES OF WATER & INDUCE (SUPDAT)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: EXTINGUISH ALL SOURCES OF IGNITION. CONTAIN SPILL.
WEAR NIOSH/MSHA APPROVED SCBA FOR CONCENTRATIONS ABOVE TLV. TAKE UP WITH
INERT ABSORBENT MATERIAL AND PLACE IN NON-LEAKING CONTAINER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: USE CONTAINER DOT CERTIFIED FOR HAZARDOUS WASTE.
DISPOSE OF ALL WASTES IN ACCCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS.
Handling And Storage Precautions: KEEP CONTAINERS CLOSED WHEN NOT IN USE. DO
NOT STORE NEAR SOURCES OF IGNITION. KEEP FROM CHILDREN. FOR INDUSTRIAL USE
ONLY.
Other Precautions: USE PROTECTIVE GEAR AS INDICATED. DO NOT START ELECTRICAL
HANDLING THIS MATERIAL.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: 101F,38C
Lower Limits: 1%
Upper Limits: 15.6%
Extinguishing Media: WATER SPRAY, FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: COOL EXPOSED CONTAINERS WITH WATER FOG TO
PREVENT EXPLOSIONS.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH/MSHA APPROVED FOR ORGANIC VAPORS FOR
CONCENTRATIONS ABOVE TLV.
Ventilation: PROVIDE VENTILATION TO KEEP AIRBORNE CONCENTRATION BELOW TLV.
Other Protective Equipment: EMERG EYE WASH AND DELUGE SHOWER WHICH MEETS ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: WASH HANDS THOROUGHLY AFTER USE AND BEFORE EATING,
DRINKING, SMOKING OR USING TOILET.
Supplemental Safety and Health: FIRST AID PROC: VOMIT WHILE KEEPING VICTIM'S
HEAD BELOW HIPS. GET IMMED MED ATTN. EFTS OF OVEREXP: IRRIT AS NOTED. CNS
DEPRESS MAY BE EVIDENCED BY GIDDINESS, HDCH, DIZZ & NAUS. UNCON &
DEATH MAY OCCUR . ASPIR PNEUM MAY BE EVIDENCED BY COUGHING, LABORED BRTHG
& CYANOSIS (BLUISH SKIN). TOLUENE & EGEE APPEAR ON NAVY
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >231F,>111C
Vapor Pres: 39.3 @ 20C
Vapor Density: 4.45
Spec Gravity: 0.778
Evaporation Rate & Reference: 2.66 (BUTYL ACETATE=1)
Solubility in Water: 6%
Appearance and Odor: WATER WHITE LIQUID WITH SWEET, AROMATIC ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: CONTACT WITH HEAT AND FLAME.
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: CARBON DIOXIDE AND CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: WM WASH
Cage: LXTHC
Company Name: LITHCO INC
Street: 9449 JEFFERSON BLVD
Zipcode: 90323-2913
Label Required IND: Y
Date Of Label Review: 12/01/1994
Status Code: C
Label Date: 12/01/1994
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Severe
Contact Hazard: Severe
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: ACUTE:INHAL:IRRIT TO MUC MEMBS & RESP TRACT,CNS
DEPRESS & LIVER,KIDNEY & BLOOD FORMING ORGAN DMG. SKIN/EYES:
IRRIT.MAY BE ABSORB THRU SKIN.SYMPS SIMILAR TO INHAL.SKIN ABSORB: KIDNEY DMG,
CHANGES IN UR INE OUTPUT/APPEAR. LIVER DMG, LOSS OF APPETITE/JAUNDICE &
SOMETIMES PAIN IN UPPER RIGHT ABDOMEN.DMG TO BLOOD FORMING ORGANS, EASY
FATIGABILITY & PALLOR.CNS DEPRESS, GIDDINESS,HDCH,DIZZ &
NAUS.INGEST:S YMPS SAME AS ABSORP.MAY CAUSE VOMIT.ASPIR INTO LUNGS MAY CAUSE
ASPIR PNEUM,COUGHING,LABORED BRTHG & CYANOSIS (BLUISH SKIN).
CHRONIC:TOLUENE & EGEE APPEAR ON NAVY LIST OF OCCUP CHEM REPROD HAZ (FP
N). MAY CAUSE KIDNEY, LIVER, BLOOD-FORMING ORGAN DMG.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:IRON STANDARD SOLUTION 50 MG/L AS IRON
CAGE:91224
CAGE:91224
CAGE:4T252
Contract Num:SP0450-97-M-D015
CAGE:7Z016
============= Composition/Information on Ingredients =============
Ingred Name:HYDROGEN CHLORIDE (HYDROCHLORIC ACID) (SARA 302/313)
(CERCLA)
CAS:7647-01-0
RTECS #:MW4025000
< Wt:1.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 5 PPM
ACGIH TLV:C 5 PPM; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:FERRIC CHLORIDE HEXAHYDRATE
CAS:10025-77-1
RTECS #:NO5425000
< Wt:.1
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: TO 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES- MAY CAUSE IRRITATION.
Effects of Overexposure:EYES- MAY CAUSE IRRITATION.
Medical Cond Aggravated by Exposure:NONE REPORTED.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH WATER FOR 15 MIN. CALL
PHYSICIAN.SKIN: WASH WITH SOAP AND PLENTY OF WATER. INHALATION:
NOT APPLICABLE. INGESTION: GIVE LARGE QUANTITIES OF WATER. CALL A
PHYSICIAN IMME DIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA APPROPRIATE TO THE SURROUNDING FIRE
CONDITIONS.
Fire Fighting Procedures:KEEP CONTAINERS COOL.
================== Accidental Release Measures ==================
Spill Release Procedures:COVER THE SPILL WITH EXCESS SODA ASH OR SODIUM
BICARBONATE. SCOOP SLURRY TO BEAKER. ADJUST PH TO BETWEEN 6 AND 9.
FLUSH TO DRAIN WITH EXCESS WATER. WASH SITE WITH AN ALKALI
SOLUTION.
Neutralizing Agent:SODA ASH OR SODIUM BICARBONATE
============= Exposure Controls/Personal Protection =============
Ventilation:ADEQUATE VENTILATION.
Other Protective Equipment:NONE
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:=100.C, 212.F
Spec Gravity:0.99
pH:1.1
Evaporation Rate & Reference:0.88 (NO REFERENCE)
Solubility in Water:MISCIBLE
Appearance and Odor:COLORLESS LIQUID. NO ODOR.
Corrosion Rate:AL:0.143 IN/YR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALIES
Stability Condition to Avoid:HEAT, EVAPORATION.
Hazardous Decomposition Products:NONE REPORTED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL,
STATE, AND LOCAL REGULATIONS.
======================================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:GARIA S
CAGE:FUCHS
CAGE:FUCHS
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL, UNSPECIFIED
Other REC Limits:OIL MIST 5MG/M3(MFR)
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: PULMONARY IRRITATION POSSIBLE.
DEFATTING ACTION ON SKIN. PROLONGED OR REPEATED CONTACT MAY CAUSE
SKIN DISORDERS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN: REMOVE
OIL BY WIPING OR APPLYING WATERLESS HAND CLEANER, FOLLOWED BY
WASHING WITH SOAP AND WATER. REMOVE ALL CONTAMINATED CLOTHING.
INGEST: INDUCE VOMITING IF CONSCIOUS & CONSULT MEDICAL PERSONNEL.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>320F,>160C
Extinguishing Media:DRY CHEMICAL TYPE PREFERRED.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE UNUSUAL.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH CLAY, DIATOMACEOUS EARTH, OR OTHER
INERT MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING OIL MIST AND VAPORS.
MINIMIZE SKIN CONTACT. AIRBORNE MIST SHOULD BE SUBSTANTIALLY BELOW
TLV FOR OIL MIST.
Other Precautions:LAUNDER CONTAMINATED CLOTHING BEFORE REUSE. DISCARD
LEATHER GOODS IF THEY CANNOT BE DECONTAMINATED. WASH BEFORE EATING
OR SMOKING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR TO AVOID EXPOSURE
TO HOT VAPOR OR MIST.
Ventilation:LOCAL EXHAUST: AS REQUIRED TO PREVENT EXPOSURE TO
VAPOR/MIST.
Other Protective Equipment:APPROPRIATE CLOTHING TO AVOID SKIN CONTACT.
Work Hygienic Practices:WASH BEFORE EATING OR SMOKING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:V6
Spec Gravity:0.91(H2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:CLOUDY, LIGHT BROWN LIQUID, SLIGHT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:HEAT AND MIST FORMATION: EXCESSIVE HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF SULFUR AND GENERATED CAN BE FORMED DURING COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED BURNING IN COMPLIANCE WITH LOCAL,
FEDERAL AND STATE REGULATIONS OR BURY IN APPROVED LANDFILL.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CAPELLA WF 68,01562
Resp. Party Other MSDS Num.:01562ET
CAGE:3N254
Contract Num:SP0450-00-W-2124
CAGE:097K0
CAGE:3N254
============= Composition/Information on Ingredients =============
Ingred Name:ACID TREATED HEAVY NAPHTHENIC DISTILLATES (PETROLEUM)
CAS:64742-18-3
RTECS #:PY8032000
Minumum % Wt:80.
Maxumum % Wt:94.99
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
ACGIH STEL:10 MG/M3 (OIL MIST)
Ingred Name:DISTILLATES (PETROLEUM), HYDROTREATED LIGHT NAPHTHENIC
CAS:64742-53-6
RTECS #:PY8036000
Minumum % Wt:10.
Maxumum % Wt:19.99
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
ACGIH STEL:10 MG/M3 (OIL MIST)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT PROVIDED BY MANUFACTURER
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-EYE: MAY CAUSE MINIMAL
IRRITATION. SKIN: BRIEF CONTACT IS NOT IRRITATING. PROLONGED
CONTACT, AS WITH CLOTHING WETTED WITH MATERIAL, MAY CAUSE DEFATTING
OF SKIN OR IRRITATION. INHALATION: VAPORS OR MIST, IN EXCESS OF
PERMISSIBLE CONCENTRATIONS, OR IN UNUSUALLY HIGH CONCENTRATIONS
GENERATED FROM SPRAYING, HEATING THE MATERIAL OR AS FROM EXPOSURE
IN POORLY VENTILATED AREAS OR CONFINED SPACES, M AY CAUSE
IRRITATION OF THE NOSE AND THROAT. INGESTION: IF MORE THAN SEVERAL
MOUTHFULS ARE SWALLOWED, ABDOMINAL DISCOMFORT, NAUSEA AND DIARRHEA
MAY OCCUR. CHRONIC: NO ADVERSE CHRONIC EFFECTS HAVE BEEN
DOCUMENTED IN HUMANS.
Explanation of Carcinogenicity:NOT PROVIDED BY MANUFACTURER
Effects of Overexposure:EYES: IRRITATION, DISCOMFORT. SKIN: DEFATTING,
IRRITATION, LOCAL REDNESS, DISCOMFORT. INHALATION: IRRITATION OF
NOSE & THROAT, HEADACHE, NAUSEA, DROWSINESS. INGESTION: ABDOMINAL
DISCOMFORT, NAUSEA, DI ARRHEA.
Medical Cond Aggravated by Exposure:BECAUSE OF ITS DEFATTING
PROPERTIES, PROLONGED AND REPEATED SKIN CONTACT MAY AGGRAVATE AN
EXISTING DERMATITIS (SKIN CONDITION).
======================= First Aid Measures =======================
First Aid:EYE: FLUSH EYES WITH PLENTY OF WATER FOR SEVERAL MINUTES. GET
MEDICAL ATTENTION IF EYE IRRITATION PERSISTS. SKIN: WASH SKIN WITH
PLENTY OF SOAP AND WATER FOR SEVERAL MINUTES. GET MEDICAL ATTENTION
IFSKIN IRRITATION DEVELOPS OR PERSISTS. INGESTION: IF MORE THAN
SEVERAL MOUTHFULS OF THIS MATERIAL ARE SWALLOWED, GIVE TWO GLASSES
OF WATER (16 OZ.). GET MEDICAL ATTENTION. INHALATION: IF
IRRITATION, HE ADACHE, NAUSEA, OR DROWSINESS OCCURS, REMOVE TO
FRESH AIR. GET MEDICAL ATTENTION IF BREATHING BECOMES DIFFICULT OR
RESPIRATORY IRRITATION PERSISTS.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:=179.4C, 355.F
Lower Limits:N/DETERMINED
Upper Limits:N/DETERMINED
Extinguishing Media:USE WATER SPRAY, DRY CHEMICAL, FOAM OR CARBON
DIOXIDE TO EXTINGUISH FLAMES. USE WATER SPRAY TO COOL FIRE-EXPOSED
CONTAINER. WATER OR FOAM MAY CAUSE FROTHING.
Fire Fighting Procedures:OTHER THAN NORMAL PROTECTIVE FIRE-FIGHTING
EQUIPMENT, NO SPECIAL EQUIPMENT OR PROCEDURES REQUIRED.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. AVOID BREATHING VAPOR. WEAR
APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT, INCLUDING APPROPRIATE
RESPIRATORY PROTECTION. CONTAIN SPILL IF POSSIBLE. WIPE UP OR
ABSORB ON SUITABLE MATERIAL A ND SHOVEL UP. PREVENT ENTRY INTO
SEWERS AND WATERWAYS. AVOID CONTACT WITH SKIN, EYES OR CLOTHING.
Neutralizing Agent:NOT PROVIDED BY MANUFACTURER
======================Handling and Storage ======================
Handling and Storage Precautions:MINIMUM FEASIBLE HANDLING TEMPERATURES
SHOULD BE MAINTAINED. PERIODS OF EXPOSURE TO HIGH TEMPERATURES
SHOULD BE MINIMIZED. WATER CONTAMINATION SHOULD BE AVOIDED.
Other Precautions:REMOVE AND DRY CLEAN OR LAUNDER CLOTHING SOAKED OR
SOILED WITH THIS MATERIAL BEFORE REUSE. DRY CLEANING OF
CONTAMINATED CLOTHING MAY BE MORE EFFECTIVE THAN NORMAL LAUNDERING.
INFORM INDIVIDUALS RESPON SIBLE FOR CLEANING OF POTENTIAL HAZARDS
ASSOCIATED WITH HANDLING CONTAMINATED CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AIRBORNE CONCENTRATIONS SHOULD BE KEPT TO LOWEST
LEVELS POSSIBLE. IF VAPOR, MIST OR DUST IS GENERATED & THE
OCCUPATIONAL EXPOSURE LIMIT OF THE PRODUCT, OR ANY COMPONENT OF THE
PRODUCT, IS EXCEEDED, US E APPROPRIATE NIOSH/ MSHA APPROVED AIR
PURIFYING OR AIR SUPPLIED RESPIRATOR AFTER DETERMINING THE AIRBORNE
CONCENTRATION OF THE CONTAMINANT. AIR SUPPLIED
Ventilation:ADEQUATE TO MEET OCCUPATIONAL EXPOSURE LIMITS.
RECOMMENDED
Other Protective Equipment:NOT PROVIDED BY MANUFACTURER
Work Hygienic Practices:WORKERS SHOULD WASH EXPOSED SKIN SEVERAL TIMES
DAILY WITH SOAP AND WATER. SOILED WORK CLOTHING SHOULD BE LAUNDERED
OR DRY-CLEANED.
Supplemental Safety and Health
PRODUCT CODE AND NAME: 01562 CAPELLA WF 68.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:NOT DETERMINED
Vapor Pres:NOT DETERMINED
Spec Gravity:.895(WATER=1)
Viscosity:64.6 CST AT 40.0C
Solubility in Water:NOT DETERMINED
Appearance and Odor:CLEAR YELLOW LIQUID; BLAND ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NOT PROVIDED BY MANUFACTURER
Hazardous Decomposition Products:TOXIC LEVELS OF CARBON MONOXIDE,
CARBON DIOXIDE, IRRITATING ALDEHYDES AND KETONES.
=================== Toxicological Information===================
Toxicological Information:MEDIAN LETHAL DOSE: ORAL: BELIEVED TO BE
>5.00 G/KG (RAT) PRACTICALLY NON-TOXIC . INHALATION: NOT
DETERMINED. DERMAL:LD50 BELIEVED TO BE <0.50/8.0 (RABBIT)
PRACTICALLY NON-TOXIC. IRRITATION INDEX, EST IMATION OF IRRITATION
(SPECIES): SKIN:(DRAIZE) BELIEVED TO BE <0.50/8.0 (RABBIT) NO
APPRECIABLE EFFECT. EYES:(DRAIZE) BELIEVED TO BE <15.00/110
(RABBIT) NO APPRECIABLE EFFECT. SENSITIZATION:NOT DETERM INED.
OTHER:LOW VISCOSITY NAPHTHENIC OILS HAVE CAUSED SKIN IRRITATION &
SKIN TUMORS IN LABORATORY ANIMALS WHEN REPEATEDLY APPLIED & LEFT IN
PLACE BETWEEN APPLICATIONS. THE SIGNIFIGANCE OF THIS EFFECT IN
HUMANS HAS NOT BEEN ESTABLISHED.
===================== Ecological Information =====================
Ecological:NOT PROVIDED BY MANUFACTURER
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS MATERIAL HAS BEEN EVALUATED FOR RCRA
CHARACTERISTICS & DOES NOT MEET THE CRITERIA OF A HAZARDOUS WASTE
IF DISCARDED IN ITS PURCHASED FORM. UNDER RCRA, IT IS THE
RESPONSIBILITY OF THE USER OF THE PRODUCT TO DETERMINE AT THE TIME
OF DISPOSAL, WHETHER THE PRODUCT MEETS RCRA CRITERIA FOR HAZARDOUS
WASTE.
=================== MSDS Transport Information ===================
Transport Information:DOT PROPER SHIPPING NAME: NOT REGULATED.
IATA/IMO: NOT DETERMINED.
===================== Regulatory Information =====================
SARA Title III Information:SECTION 302/304: NONE. SECTION 311/312
HAZARD CATAGORIZATION: ACUTE. SECTION 313: NONE.
Federal Regulatory Information:CERCLA 102(A)/DOT HAZARDOUS SUBSTANCES:
NONE. TSCA INVENTORY STATUS: THIS PRODUCT OR ITS COMPONENTS ARE
LISTED ON OR ARE EXEMPT FROM THE TOXIC SUBSTANCE CONTROL ACT (TSCA)
CHEMICAL SUBSTANCE INVENTORY .
State Regulatory Information:CALIFORNIA PROPOSITION 65: THE FOLLOWING
DETECTABLE COMPONENTS OF THIS PRODUCT ARE SUBSTANCES, OR BELONG TO
CLASSES OF SUBSTANCES, KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER AND/OR REPRODUCTIVE: NONE.
======================= Other Information =======================
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:M/M DOUBLE DUTY BLOCKS, T270
Preparer's Name:L. DEYOUNG
CAGE:0TTE8
CAGE:0TTE8
============= Composition/Information on Ingredients =============
Ingred Name:BENZENE, P-DICHLORO-; (P-DICHLOROBENZENE) (SARA 313)
(CERCLA) LD50: (ORAL, RAT) 3826 MG/KG
CAS:106-46-7
RTECS #:CZ4550000
OSHA PEL:75 PPM
ACGIH TLV:10 PPM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:SUPDAT: BODY WT, SOME ORGAN WTS & CLINICAL PARAMETERS,
PORPHYRIA & KIDNEY DMG (MALE RATS ONLY) W/LIVER TOXICITY. (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2: CHANGES IN BONE MARROW, SPLEEN, THYMUS & NASAL
TURBINATES WERE ALSO OBSERVED IN RATS AT DOSAGES WHICH (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3: PRODUCED SOME DEATHS.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: SURF OF EYES & LIDS W/WATER. GET IMMED MED
ATTN. SKIN: WASH AFFECTED AREAS W/LG AMTS OF RUNNING (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: WATER & SOAP IF AVAIL FOR 15 MIN. REMOVE CONTAMD
CLTHG & SHOES. GET IMMED MED ATTN. WASH CLTHG & CLEAN (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: SHOES BEFORE REUSE. INGEST: GIVE 3 TO 4 GLASSES OF
WATER BUT DO NOT INDUCE VOMIT. IF VOMIT OCCURS, GIVE (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: FLUIDS AGAIN. GET MED ATTN TO DETERMINE WHETHER
VOMIT OR EVACUATION OF STOMACH IS NECESSARY. DO NOT GIVE (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: ANYTHING BY MOUTH TO AN UNCON OR CONVULSING PERSON.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:CAUSES EYE IRRIT. CAUSES SKIN
IRRIT & BURNING SENSATIONS. INHAL CAN CAUSE NASAL & RESP TRACT
IRRIT. INGEST MAY BE HARMFUL & MAY CAUSE NAUS & VOMIT. CHRONIC:
EXTENDED/PRLNGD INHAL MAY CAUSE HDCH, SWELL AROUND EYES, INFLAM OF
MUC MEMBSOF NOSE, LOSS OF APPETITE, NAUS OR VOMIT & POSS LIVER &
KIDNEY (EFTS OF OVEREXP)
Explanation of Carcinogenicity:BENZENE, P-DICHLORO: IARC MONOGRAPHS,
SUPP, VOL 7, PG 192, 1987:GROUP 2B. NTP 7TH ANNUAL REPORT ON
CARCINS, (SUPDAT)
Effects of Overexposure:HLTH HAZ: DMG. INGEST IN HIGH DOSES MAY CAUSE
LIVER & KIDNEY INJURY & JAUNDICE. TARGET ORGANS: LIVER & KIDNEY.
RPTD INHAL STUDIES (UP TO 14 WEEKS) W/P-DICHLOROBENZENE CONDUCTED
IN RATS, RABBITS, GUINE A PIGS & DOGS HAVE RSLTD IN LIVER & KIDNEY
TOX, LUNG EFTS, REVERSIBLE EYE CHANGES (RABBITS ONLY), REDUCED BODY
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM AREA TO FRESH AIR. IF NOT BRTHG, CLEAR
AIRWAY & START MOUTH-TO-MOUTH ARTF RESP OR USE BAG-MASK RESP. GET
IMMED MED ATTN. IF VICTIM IS HAVING TROUBLE BRTHG, TRANSPORT TO MED
CARE & I F AVAIL GIVE SUPPLEMENTAL OXYGEN. EYES:IMMED RINSE
W/WATER. REMOVE ANY CONTACT LENSES & CONTINUE FLUSHING W/RUNNING
WATER FOR AT LEAST 15 MIN. HOLD EYELIDS APART TO ENSURE RINSING OF
ENTIRE (ING 5)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:150F,66C
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:UPON BURNING, MAY FORM OXIDES OF CARBON,
CHLORIDES AND CHLORINE GAS.
================== Accidental Release Measures ==================
Spill Release Procedures:MATERIAL CONSISTS OF A SOLID BLOCK WRAPPED IN
PROTECTIVE PLASTIC TO PREVENT SUBLIMATION. IF MATERIAL BREAKS OR IS
SCATTERED, SWEEP UP AND PUT IN A LABELED CONTAINER FOR PROPER
DISPOSAL.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT USE OR STORE NEAR HEAT OR OPEN
FLAME. STORE AT MODERATE TEMPERATURES, IN A WELL-VENTILATED AREA.
WASH THOROUGHLY AFTER HANDLING.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. READ THE ENTIRE LABEL
BEFORE USING THIS PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR EMERGENCIES OR WORK IN CONFINED AREAS, WEAR
NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS OR SUPPLIED-AIR
RESPIRATORY PROTECTION.
Ventilation:GENERAL OR MECHANICAL EXHAUST TO MAINTAIN EXPOSURE LEVELS
BELOW TLV.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLAN OF CARCIN: 1994:ANTIC TO BE CARCIN. ANIMAL:KIDNEY, BLADDER,
URETER, LIVER. EFTS OF OVEREXP: WT & NUMBER OF WHITE BLOOD CELLS,
CLINICAL SIGNS & ANIMAL DEATHS AT HIGH EXPOS LEVELS WHILE NO EFTS R
EPORTED IN MICE/MONKEYS. NO ADVERSE EFTS OBSERVED IN RATS FOLLOWING
RPTD SKIN EXPOS BUT EXHIBITED CHANGES IN (ING 2)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:345F,174C
Vapor Pres:0.6
Vapor Density:5.1
Spec Gravity:1.458 (H*2O=1)
Evaporation Rate & Reference:0.15 (BU A/C=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLUE, OPAQUE SOLID; CHERRY/MOTHBALL ODOR.
Percent Volatiles by Volume:99
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:HEAT, HOT SURFACES, SPARKS AND OPEN FLAME.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
CHLORIDES, CHLORINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH STATE, FEDERAL AND
LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:PETERS PROFESSIONAL SOLUBLE FERTILIZER
CAGE:WRGRA
CAGE:WRGRA
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM NITRATE
CAS:7757-79-1
RTECS #:TT3700000
Fraction by Wt: 50%
Other REC Limits:NONE SPECIFIED
Ingred Name:AMMONIUM NITRATE (SOLUTION) (SARA III)
CAS:6484-52-2
RTECS #:BR9050000
Fraction by Wt: 20%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RAT LD50: 3,750 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SLIGHTLY IRRITATING TO EYES, SKIN IF
DUST IS CREATED AND LARGE AMOUNTS ARE INHALED, NAUSEA, HEADACHE AND
RESPIRATORY IRRITATION MAY OCCUR. INGESTION: CAUSES IRRITATION TO
THE LININGS OF THE GI TRACT, ABDOMINAL CRAMPS, DIARRHEA AND
VOMITING.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:MAY CAUSE EYE, SKIN & RESPIRATORY TRACT
IRRITATION. MAY ALSO CAUSE HEADACHE, DIZZINESS AND NAUSEA.
ASPIRATION PNEUMONITIS MAY CAUSE COUGHING, LABORED BREATHING,
CYANOSIS, AND IN SEVERE CASES, DEATH.
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH RUNNING WATER FOR 15 MINUTES WHILE HOLDING
EYELIDS OPEN. SKIN: WASH WITH SOAP AND WATER. INHALATION: REMOVE TO
FRESH AIR. INGESTION: INDUCE VOMITING. RINSE MOUTH & DRINK LARGE
AMOUNTS OF WATER. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NA
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:THIS PRODUCT MAY CONTAIN AMMONIUM NITRATE
AND POTASSIUM NITRATE WHICH ARE OXIDIZERS IN THEIR PURE OR UNMIXED
FORMS. TREAT DRY PRODUCT AS AN OXIDIZER IN FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP INTO DRY CONTAINERS, RECYCLE OR REMOVE
FOR DISPOSAL. PREVENT PRODUCT FROM ENTERING WATER SYSTEMS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP
CONTAINERS CLOSED WHEN MATERIAL IS NOT IN USE. KEEP AWAY FROM
IGNITION SOURCES. AVOID PROLONGED OR REPEATED CONTACT.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED CHEMICAL CARTRIDGE
RESPIRATOR IN DUSTY AREA.
Ventilation:LOCAL AND MECHANICAL(GENERAL) EXHAUST TO PROVIDE ADEQUATE
VENTILATION.
Other Protective Equipment:WEAR INDUSTRIAL WORK CLOTHING. USE RUBBER
APRON OR BOOTS IF NEEDED. HAVE EMERGENCY EYE WASH AND SAFETY SHOWER
AVAILABLE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING, DRINKING OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MIST. DO NOT INGEST. READ PRECAUTIONS ON
LABEL BEFORE USE.
================== Physical/Chemical Properties ==================
HCC:D1
Boiling Pt:B.P. Text:NA
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:NA
pH:NEUTRL
Evaporation Rate & Reference:NA
Solubility in Water:COMPLETE
Appearance and Odor:AQUA BLUE CRYSTALLINE SOLID WITH MILD YEASTY ODOR
Percent Volatiles by Volume:NA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:AMMONIA GAS, NITROUS OXIDES, SULFUR
OXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL OF WASTE AND HAZARDOUS MATERIAL SHALL
COMPLY WITH LOCAL, STATE AND FEDERAL ENVIRONMENTAL PROTECTION
AGENCY REGULATIONS. SEND WASTE MATERIAL TO AN APPROVED RECYCLING
FACILITY IF FEASIBLE. CITY , STATE AND FEDERAL REGULATIONS MUST
BEFOLLOWED.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:B & B GREASE 70919
CAGE:EO135
CAGE:86961
CAGE:EO135
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM
HYDROCARBONS,PARAFFINIC,NAPHTHENIC;AROMATIC(AROMATICS CONTAIN
POLYCYLCIC CMPDS)
Fraction by Wt: 86%
Ingred Name:FATTY OILS
Fraction by Wt: 9%
Ingred Name:LEAD ALKYL DITHIOCARBAMATE
Fraction by Wt: 1%
Ingred Name:NAPHTHENATE SULFONATES
Fraction by Wt: 1%
Ingred Name:CALCIUM SOAP THICKENER
Fraction by Wt: 1%
===================== Hazards Identification =====================
Effects of Overexposure:INH: POSS PULM IRRIT,DIZZ,NAUS. SKIN:
DERMATITIS,FOLLICULITIS OR OIL ACNE;POSS ABSORPTION OF LEAD
======================= First Aid Measures =======================
First Aid:INGES: DO NOT INDUCE VOMITING. NO TREATMENT USUALLY NEEDED
UNLESS LG AMOUNTS INGES, SEE MD. SKIN:REMOVE CONTAMINATED CLOTHING
& WIPE EXCESS OFF. WASH W/ SOAP & H*2O OR WATERLESS CLEANER,THEN
SOAP & WA TER. WASH CLOTHES BEFORE REUSE.(SEE OTHER PRECAUTN
===================== Fire Fighting Measures =====================
Flash Point:331F;166C (PMCC)
Extinguishing Media:WATER FOG,FOAM,DRY CHEM,CO*2
Fire Fighting Procedures:USE PROTECTIVE CLOTHING & SCBA. COOL CANS W/
WATER.
Unusual Fire/Explosion Hazard:DO NOT USE A DIRECT STREAM OF WATER.
PRODUCT WILL FLOAT AND CAN BE REIGNITED ON SURFACE OF WATER.
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP UP EXCESS GREASE. CLEAN AREA W/
APPROPRIATE CLEANER. KEEP OUT OF SURFACE WATERS & ANY WATER COURSES
OR SEWERS ENTERING OR LEADING TO SURFACE WATERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY PLACE W/ ADEQUATE
VENT. KEEP FROM OPEN FLAMES & HI TEMP. WASH BEFORE
SMOKING,EATING,ETC.
Other Precautions:FIRST AID PROCEDURES: SKIN- IF IRRIT PERSIST,CALL MD.
EYES- FLUSH W/ H*2O FOR 15 MIN HOLDING EYELIDS APART. SEE MD. HAZ
DECOMPOSITION PROD: PHOSPHOROUS OXIDES & UNIDENTIFIED ORGANIC
MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT ORDINARILY NEEDED (MFR)
Ventilation:USE WITH ADEQUATE VENTILATION.
Other Protective Equipment:CLOTHING TO MINIMIZE CONTACT
Supplemental Safety and Health
INGRED: FATTY ACIDS-<1%,AROMATIC AMINES-<0.5%,WAXES-<0.5%. THE PRESENCE
OF POLYCYCLIC AROMATICS (CANCER INDUCING IN LAB ANIMALS) REQUIRES
PRECAUTIONS TO AVOID CONTACT.
================== Physical/Chemical Properties ==================
HCC:V6
Evaporation Rate & Reference:NOT AVAILABLE(N/A)
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER TO DARK, SMOOTH; SLIGHT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT,OPEN FLAME
Hazardous Decomposition Products:CO,NITROGEN OXIDES,SULFUR OXIDE (SEE
OTHER PRECAUTIONS)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL METHOD MUST BE IAW FEDERAL, STATE &
LOCAL CODES.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SCOTCHGRIP 1300 ADHESIVE (OLD FORMULA)
CAGE:04963
CAGE:04963
============= Composition/Information on Ingredients =============
Ingred Name:ALIPHATIC PETROLEUM NAPHTHA (APN)
Fraction by Wt: 35.0%
ACGIH TLV:200 PPM
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 20.0%
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <5.0%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:EYE IRRITANT, MAY DEFAT SKIN.VAPOR MAY IRRITATE
UPPER RESPIRATORY SYSTEM.NARCOSIS & DIZZINESS
======================= First Aid Measures =======================
First Aid:EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER.CALL MD.
SKIN:WASH WITH SOAP & WATER. INHALATION:REMOVE TO FRESH AIR.
INGESTION:DO NOT INDUCE VOMITING. CALL MD.
===================== Fire Fighting Measures =====================
Flash Point:-14.0F (F.C.C.)
Lower Limits:1.8
Upper Limits:11.
Extinguishing Media:CO, FOAM, DRY CHEMICAL
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. COLLECT SPILLED
MATERIAL & PLACE IN CLOSED METAL CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:EXTREMELY FLAMMABLE REMOVE ALL SOURCES
OF IGNITION.USE ONLY IN WELL VENTILATED AREAS.AVOID EYE
CONTACT.AVOID PROLONGED BREATHING OF VAPOR.
Other Precautions:AVOID PROLONGED OR REPEATED SKIN CONTACT. KEEP
CONTAINER CLOSED WHEN NOT IN USE.
============= Exposure Controls/Personal Protection =============
Supplemental Safety and Health
THIS NSN CANCELLED IN 1974 AND REPLACED BY 8040-00-514-1880, THEN BY
8040-00-273-8717, A NEW FORMULATION FOR THIS PRODUCT.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:140F
Vapor Pres:180
Vapor Density:3.0
Spec Gravity:0.88
Evaporation Rate & Reference:>2.5 ETHER
Appearance and Odor:YELLOW LOW VISCOSITY LIQUID STRONG SOLVENT ODOR
Percent Volatiles by Volume:62.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO, CO*2, & CHLORINATED DECOMPOSITION
PRODUCTS
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT LANDFILL. INCINERATE IN ACCORDANCE WITH
LOCAL, STATE & FED CODES.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:OMNI-BOND ADHESIVE WITH MIXERS 43457 PART B
CAGE:18399
CAGE:18399
============= Composition/Information on Ingredients =============
Ingred Name:M-PHENYLENEBIS-METHYLAMINE (XYLENE DIAMINE). LD50 RAT ORAL
930 MG/KG .
CAS:1477-55-0
RTECS #:PF8970000
Fraction by Wt: 3%
Other REC Limits:N/K
OSHA PEL:0.1 MG/M3 C, SKIN
ACGIH TLV:0.1 MG/M3 C, SKIN
Ingred Name:DIETHYLTOLUENE DIAMINE. LD50 RAT ORAL 485 MG/KG, RABBIT
DERMAL 700 MF/KG (MFR).
CAS:68479-98-1
Fraction by Wt: 4%
Other REC Limits:0.1 PPM (MFR)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:AROMATIC BISTHIODIAMINE. LD50 RAT ORAL 10000 MG/KG, RABBIT
DERMAL 2000 MG/KG (MFR).
CAS:52411-33-3
Fraction by Wt: 10%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 EST RABBIT DERMAL 4666 MG/KG (MFR)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXCESSIVE OR CHRONIC EXPOSURE MAY
CAUSE LIVER DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: EYE IRRITATION. SKIN: IRRITATION.
INGESTION: MODERATELY TOXIC BY ORAL EXPOSURE. INHALATION: VERY
TOXIC.
Medical Cond Aggravated by Exposure:N/K
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15
MIN AND CALL A PHYSICIAN. SKIN: WASH WITH ISOPROPANOL AND THEN
PLENTY OF SOAP AND WATER. INGESTION: SEEK PHYSICIAN IMMEDIATELY,
SHOW MSDS O R LABEL. DO NOT INDUCE VOMITING. INHALATION: REMOVE TO
FRESH AIR, ADMINISTER OXYGEN AND CALL PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:200F,94C
Lower Limits:0.9%
Upper Limits:9.5%
Extinguishing Media:EXTINGUISH WITH WATER, FOG, FOAM, DRY CHEMICAL,
CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SELF-CONTAINED
BREATHING APPARATUS AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CONTACT WITH FLAME, HOT SURFACE, MAY
PRODUCE TOXIC GASES. VERY TOXIC BY INHALATION.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA, VENTILATE AREA, WEAR APPROVED
AND EYE/ FACE PROTECTION. CLEAN UP WITH ABSORBENT MATERIAL, CONTAIN
AND PICK UP WASTE MAT ERIAL, PUT IN SEALED APPROVED CONTAINER.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT AND FLAME. USE W/
ADEQ VENT. AVOID PROLONG BREATHING OF VAPS/SPRAY MIST, SKIN/EYE
CONTACT. DO NOT INGEST. KEEP CONTAINER CLOSED.
Other Precautions:FOR PROFESSIONAL & INDUSTRIAL USE ONLY.KEEP OUT OF
REACH OF CHILDREN.IN CASE OF ACCIDENT/ILLNESS,SEEK MD IMMED & SHOW
MSDS/ LABEL.ALWAYS READ & FOLLOW DIRECTIONS ON PROD LABEL.ADDNL
TECHNICAL DATA SHE ETS/MSDS ARE AVAIL FROM MFR ON REQUEST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL & GENRL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .GENERAL AND LOCAL EXHAUST REQUIRED.
Other Protective Equipment:WEAR SUITABLE PROTECTIVE CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY AFTER USE.
Supplemental Safety and Health
ROUTES OF ENTRY: SKIN CONTACT, EYE (MANUFACTURER). EYE PROT: FACESHIELD
================== Physical/Chemical Properties ==================
HCC:T6
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:0.3
Spec Gravity:1.05,WATER=1
Evaporation Rate & Reference:NIL
Solubility in Water:NIL
Appearance and Odor:AMBER LIQUID WITH A MILD ODOR.
Percent Volatiles by Volume:>0.01
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES, WATER, PEROXIDES.
Stability Condition to Avoid:HEAT, FLAME, AND MOISTURE.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
AMINES, PYROLYSIS PRODUCTS.
Conditions to Avoid Polymerization:KEEP AWAY FROM HEAT AND FLAME.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:349522 CYCLE TEST CITRATE BUFFER
Kit Part:Y
Preparer's Name:ANNA LONGWELL
CAGE:06531
CAGE:06531
CAGE:0GKS0
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NO INHALATION HAZARD. PRODUCT IS
NON-IRRITATING & NON-SENSITIZING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NO INHALATION HAZARD. PRODUCT IS NON-IRRITATING
& NON-SENSITIZING.
======================= First Aid Measures =======================
First Aid:EYES: GENTLY FLUSH W/TEPID WATER. SKIN: RINSE W/WATER & MILD
SOAP. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NON-COMBUSTIBLE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB MATERIAL W/PAPER TOWELS/OTHER
ABSORBENTS. MINIMIZE SKIN CONTACT DURING CLEANUP THROUGH USE OF
SKIN PUNCTURES.
======================Handling and Storage ======================
Other Precautions:AVOID EYE CONTACT/PROLONGED SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED
Ventilation:NOT REQUIRED
Other Protective Equipment:NOT REQUIRED
Work Hygienic Practices:EMPLOY GOOD HYGIENIC PRACTICES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:215.6F
Vapor Pres:21.2
Spec Gravity:1.05
Evaporation Rate & Reference:(BU ACETATE=1): 2
Solubility in Water:COMPLETE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACID CHLORIDES, PHOSPHORUS HALIDES, STRONG ACIDS, OXIDIZING AGENTS &
REDUCING AGENTS
Hazardous Decomposition Products:SULFUR OXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ZE-4B ZYGLO EMULSIFIER
Kit Part:Y
Preparer's Name:BRUCE C. GRAHAM
CAGE:37676
CAGE:37676
============= Composition/Information on Ingredients =============
Ingred Name:DISTILLATES (PETROLEUM),HYDROTREATED HEAVY NAPHTHENIC
CAS:64742-52-5
RTECS #:PY8035000
Fraction by Wt: >60.0%
Ingred Name:TERPINEOL,ALPHA-
CAS:98-55-5
RTECS #:WZ6700000
Fraction by Wt: 10.0%
Ingred Name:UNIDENTIFIED COMPONENTS
Fraction by Wt: <30.0%
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:ACUTE:MAY IRRITATE EYES. SEE
OVEREXPOSURE SYMPTOMS.
Effects of Overexposure:INHALATION:NOT LISTED BY
MANUFACTURER.HOWEVER,FINE SPRAY/MIST MAY CAUSE IRRITATION TO
BREATHING PASSAGES; EYES:LIQUID/MIST CAUSES IRRITATION;
SKIN:PROLONED OR REPEATED CONTACT CAUSES IRRITATION BY DIS SOLVING
SKIN OILS; INGESTION:NOT NOTED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY THE MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR; SKIN:REMOVE CONTAMINATED
CLOTHES.WASH OFF PROMPTLY WTIH SOAP AND WATER.USE SOOTHING
LOTION.GET MEDICAL HELP IF IRRITATION PERSISTS; EYES:IMMEDIATELY
RINSE EYES WITH COP IOUS AMOUNT OF WATER.GET MEDICAL ASSISTANCE IF
IRRITATION PERSISTS; INGESTION:NOT STATED BY MANUFACTURER.GET
MEDICAL ATTENTION IF INGESTED.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F/>93C
Lower Limits:6.0
Upper Limits:1.0
Extinguishing Media:CARBON DIOXIDE,FOAM
Fire Fighting Procedures:KEEP CONTAINERS COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:WHEN INVOLVE IN COMBUSTION,MAY EMIT TOXIC
GASES AT OR ABOVE DECOMPOSITION TEMPERATURE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES.SM QTY:WIPE UP OR MOP
UP BUT DO NOT BREATHE VAPORS.PLACE RAGS IN CLOSED DRUMS; LG
QTY:WEAR PERSONAL SAFETY EQUIPMENTS.DIKE AREA FAR AHEAD.ABSORB
LIQUID WITH COMMERCIAL ABSORBEN T.TRANSFER WASTE MATL IN SALVAGE
TANKS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HEAT SOURCES IN WELL
VENTILATED AREA.AVOID AGAINST PHYSICAL DAMAGE TO CONTAINERS.KEEP
CONTAINERS TIGHTLY CLOSED.
Other Precautions:DO NOT BREATHE VAPORS.DO NOT SMOKE WHILE USING.DO NOT
HEAT ABOVE 130F(54C).AVOID FREQUENT OR PROLONGED SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATORS FOR CONFINED
AREAS.
Ventilation:GENERAL ROOM VENTILATION TO KEEP BELOW TLV LIMITS.
Other Protective Equipment:NOT KNOWN
Work Hygienic Practices:WASH OFF PROMPTLY WITH WATER.AVOID SKIN CONTACT
Supplemental Safety and Health
NSN IS FOR A 2 PARTS SET OF MIL-I-25135D I/A/W QPL-25135-15,THE SET
UNDER TYPE I,METHOD B,LEVEL 2 MAY CONSIST OF ZL-2C OR ZL-2D
PENETRANT AND ZE-3 OR ZE-4B EMULSIFIER.THIS ENTRY DESCRIBES
ZE-4B;THE QP L ALSO INDICATES THAT THIS PRODUCT CAN GO IN SEVERAL
OTHER KITS OF TYPE I,METHOD A,B,C,D & LEVEL 1,2,3,4;KEY1:N1
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:410F/210C
Vapor Pres:0.25 @100F
Vapor Density:>1.0
Spec Gravity:0.92
Solubility in Water:NEGLIGIBLE
Appearance and Odor:PINK OILY LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NOT KNOWN
Stability Condition to Avoid:HEAT,HIGH TEMPERATURES
Hazardous Decomposition Products:EMITS OXIDES OF CARBON WHEN BURNING.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR DISPOSE OF AS EPA HAZARDOUS WASTE
D001 (IGNITABLE WASTE),IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL,STATE,LOCAL REGULATIONS;IF LOCAL AUTHORITIES PROHIBIT
DUMPING RINSINGS DOWN THE SEWER,P URIFY RINSINGS WITH MAGNAFLUX
WASTEWATER TREATMENT
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:LOKWELD 105 ADHESIVE
Preparer's Name:ELDEN C. CHEATHAM
CAGE:20706
CAGE:20706
CAGE:0JWR2
============= Composition/Information on Ingredients =============
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA 313)
(CERCLA)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:350 PPM
ACGIH TLV:350 PPM/450STEL;9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE
HEADACHES,DIZZINESS,DROWSINESS,HEART BEAT IRREGULARITIES,EYE
IRRIT.PROLONG/REPEATED EXPO MAY CAUSE SKIN IRRIT.
Explanation of Carcinogenicity:PER
MSDS:CARCINOGENICITY:NTP/IARC/OSHA:NO.
Effects of Overexposure:HEADACHES,DIZZINESS,DROWSINESS,HEART BEAT
IRREGULARITIES,EYE IRRIT, SKIN IRRIT.
Medical Cond Aggravated by Exposure:UNKNOWN.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR-USE RESPIRATORY PROTECTION IF
NECESSARY.SEEK MED ATTN.SKIN/EYE:FLUSH W/WATER;SEEK MED
ATTN.INGEST:TREAT SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:NP
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:CO2, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS (SCBA).
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILLS:SOAK UP SPILL W/ABSORBENT
MATERIAL OR MOP UP W/RAGS.MATERIAL OR RAGS SHOULD BE PUT INTO
CLOSED CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID SKIN/EYE CONTACT.AVOID BREATH OF
VAPORS.HANDLE CAUTIOUSLY.USE IN WELL-VENTILATED AREA.
Other Precautions:STORE IN DRY COOL PLACE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ORGANIC VAPOR CARTRIGE RESPIRATOR-ONLY IF NOT
OXYGEN DEFICIENT.
Ventilation:LOC EXHAUST-YES.MECHANICAL(GENERAL)-YES,TO PROVIDE CONTROL
BELOW PEL.
Other Protective Equipment:NO SPECIAL PROTECTIVE CLOTHING REQUIRED.
Work Hygienic Practices:APPLY GOOD HOUSEKEEPING PROCEDURES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:T4
Boiling Pt:B.P. Text:165F,74C
Melt/Freeze Pt:M.P/F.P Text:NA
Decomp Temp:Decomp Text:NP
Vapor Pres:100
Vapor Density:1.0
Spec Gravity:1.3
pH:NP
Viscosity:NP
Evaporation Rate & Reference:1.0, BUTYL ACETATE=1
Solubility in Water:INSOLUBLE
Appearance and Odor:MILD, CHLOROFORM-LIKE ODOR
Percent Volatiles by Volume:NP
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER-SLOW HYDROLYSIS PRODUCES CORROSIVE ACID.
Stability Condition to Avoid:THERMAL DECOMPOSITON (OPEN FLAMES,WELDING
ARCS) MAY YIELD HCL AND PHOSGENE.
Hazardous Decomposition Products:HCL AND VERY SMALL AMOUNTS OF
PHOSGENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:ACCORDING TO LOCAL REGUALTIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:T2 FIXER SYSTEM CLEANER
CAGE:0HZE6
CAGE:0HZE6
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 80-90%
Ingred Name:SODIUM HYDROXIDE, CAUSTIC SODA, LYE *96-4*
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 9-15%
Other REC Limits:2MG/M3 CEILING NIOSH
OSHA PEL:2 MG/CUM
ACGIH TLV:2 MG/CUM CEILING
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DANGER CAN CAUSE ALLERGIC REACTION.
CAUSES SEVERE SKIN & EYE BURNS. HARMFUL IF INHALED. VAPOR EXTREMELY
IRRITATING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, BURNS
======================= First Aid Measures =======================
First Aid:EYES: WASH IMMEDIATELY. FLUSH W/STEADY STREAM OF FRESH WATER
FOR 15 MINS. INHALATION: REMOVE TO FRESH AIR. IF BREATHING IS
DIFFICULT, GIVE OXYGEN. SKIN: RINSE W/WATER & WASH THOROUGHLY AFTER
CONTACT W /WARM SOAP & WATER. INGESTION: CAUSTIC SOLUTION. DON'T
INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, FOAM, DRY CHEMICAL
Fire Fighting Procedures:KEEP CONTAINERS COOL W/WATER SPRAY
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL WEAR PROTECTIVE CLOTHING. WIPE/ABSORB
W/SAND, CLAY/OTHER ABSORBENT MATERIALS. PICK UP CONTAINERS & PLACE
IN DRUMS/OTHER SUITABLE CONTAINERS. ABSORB RESIDUE W/ABSORBENT
MATERIALS, MOP & PLACE & D ISPOSABLE CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T CONSUME FOOD, DRINK/TOBACCO IN
AREA WHERE CONTACT W/PRODUCT MAY OCCUR. STORE IN AREA W/OTHER
ALCOHOLS, PROVIDE GENERAL EXHAUST.
Other Precautions:KEEP CONTAINER TIGHTLY CLOSED. AVOID INCOMBATIBLE
SUBSTANCES. AVOID UNNECESSARY PERSONNAL CONTACT. WASH THOROUGHLY
AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED VAPOR RESPIRATOR. GOOD GENERAL
VENTILATION
Ventilation:GOOD GENERAL
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F
Melt/Freeze Pt:M.P/F.P Text:<30F
Vapor Pres:<17 MMHG
Vapor Density:6 MMHG
Spec Gravity:1.1
pH:12
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID
Percent Volatiles by Volume:85
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ENAMEL ALKYD LUST BROWN 30117 ID 741012
Preparer's Name:W.A. ELLISON
CAGE:FO127
CAGE:FO127
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:VM&P NAPHTHA (LIGROINE)
CAS:8032-32-4
RTECS #:OI6180000
OSHA PEL:300 PPM/400 STEL
ACGIH TLV:300 PPM; 9192
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SILICA, CRYSTALLINE-CRISTOBALITE
CAS:14464-46-1
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.05 MG/M3 RDUST9293
Ingred Name:SILICA, CRYSTALLINE - FUSED
CAS:60676-86-0
RTECS #:VV7328000
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:IRON OXIDE
CAS:1309-37-1
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
Ingred Name:TALC (CONTAINING NO ASBESTOS)
CAS:14807-96-6
RTECS #:WW2710000
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST; 9192
Ingred Name:IRON OXIDE
CAS:1309-37-1
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
Ingred Name:LEAD (SARA III)
CAS:7439-92-1
RTECS #:OF7525000
OSHA PEL:0.05 MG/M3;1910.1025
ACGIH TLV:0.15 MG/M3;DUST 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:VOC. ORGANIC CMPD 3.7 LB/GL LESS WATER & NPRS* 444 G/L LESS
WATER VOC 8.5 LB/GAL SOLIDS 1020 G/L SOLIDS CALCULATED
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SWALLOWING: CAN CAUSE GASTROINTESTINAL
IRR/NAUSEA/VOMIT. ASPIRATION OF MAT'L MAYCAUSE CHEM PNEUMONITIS.
INHALATION: NOSE/THROAT IRRITA. HIGH CONCENTRATION MAY CAUSE
CENTRAL NERVOUS SYSTEM DEPRESSION CHAR BY
HEADACHES/DIZZINESS/NAUSEA/CONFUSION. EYE: MAY CAUSE EYE IRRITA.
SKIN: MAY CAUSE DEFATTING AND IRRITATION.
Effects of Overexposure:REPEATED EXPOSURE TO CRYSTALLINE SILICA MAY
CAUSE PNEUMOCONIOSIS. OCCUPATIONALOVEREXPOSURE TO SOLVENTS ASSOC
W/PERM BRAIN/NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY
CONCENTRATING/INHALING CONT MA Y BE HARMFUL/FATAL. OVEREXP
XYLENE-INJU-RY LIVER/KIDNEYS/BLOOD. LEAD-BLOOD DAMAGE &
NERVOUS/URINARY/REPRODUCTIVE SYSTEMS
======================= First Aid Measures =======================
First Aid:SWALLOWING: INDUCE VOMIT IMMED BY GIVING TWO GLASSES
WATER/STICKING FINGER DOWN THROAT/NEVER GIVE ANYTHING BY MOUTH TO
UNCONS PERSON. GET MED ATTN. INHALATION: REMOVE TO FRESH AIR. IF
BREATHING STOPPE D GIVE CPR. GET MED ATTN. EYE: FLUSH W/WATER FOR
15 MIN LIFTING UPPER/LOWER LIDS. GET MED ATTN. SKIN: WASH AFFECTED
AREA. GET MED ATTN IRR PERSISTS. TREATMENT REQ DIR AT CONTROL OF
SYM/CLIN CONDI.
===================== Fire Fighting Measures =====================
Flash Point:80F 38.89C
Extinguishing Media:USE NFPA CLASS B FIRE EXTINGUISHERS. POLYMER FOAM
IS PREFERRED FOR LARGE FIRES.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS. WATER
TO COOL CONT TO PREVENT POSSIBLE AUTO-IGNITION OR EXPLOSION. IF
WATER IS USED, FOG NOZZLES ARE PREFERABLE.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT/ELECTRICAL EQUIPMENT/SPARKS/ FLAME. CLOSED CONTAINERS
MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIM ALL IGNITION SOURCES. DIKE/CONTAIN SPILL
WITHINERT MAT'L. TRANSFER LIQ'S/ABSORBENT DIKING MAT'LIN COVERED
METAL CONT'S FOR RECOVERY/DISPOSAL. USEONLY NON-SPARKING TOOLS.
PREVENT CONTAM OF SEWERS/ STREAMS/GROUNDWATER W/SPILLED MAT'L/USED
ABSORBENT
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. STORE LARGE
QUANTITIES INCOMPLIANCE WITH OSHA 29 CFR 1910.106.
Other Precautions:DO NOT BREATHE SANDING DUST OR REUSE EMPTY CONT. DO
NOT TAKE INTERN. CONT'ER S/BGROUNDED AND BONDED TO THE RECEIVING
CONTAINER. DO NOT WELD/BRAZE OR CUT CONT'R.NEVER USE PRESSURE TO
EMPTY. DRUM IS NOTA PRESSURE VESSEL. CLOSE AFTER EA USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WELL VENTILATED AREA-USE NIOSH MECHANICAL FILTER
RESPIRATOR. RESTRICTED VENTIL- LATION USE A NIOSH (COMBINATION CHEM
CARTRIDGE/MECHAN FILTER) RESP. IN CONFINED AREAS USE NIOSH APPROVED
AIR-SUPPLIED RE SPRIATOR. REFER TO OSHA 29CFR1910.1025.
Ventilation:PROVIDE DILUT/LOCAL EXH VENT TO KEEP CONCENT OF HAZ INGRID
BELOW EXPOSURE LMT STD. REMOVE PROD GEN-WELD/CUT/BRAZ OBJECT
Other Protective Equipment:NOT LIKELY TO BE NEEDED.
Work Hygienic Practices:WASH WITH SOAP AND WATER HANDS/FACE THOROUGHLY
BEFORE EATING OR DRINKING.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:193F 395F
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:56
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BURNING, INCLUDING WHEN HEATED BY
WELDING/CUTTING, WILL PRO-DUCE SMOKE/CARBON MONOXIDE/CARBON
DIOXIDE/OXIDES OF LEAD.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE ONLY IN EPA PERMITTED FACILITY.
DISPOSEONLY IAW FED/STATE/LOCAL REGS. DO NOT INCINERATE CLOSED
CONTAINERS. OBSERVE PRECAUTIONS FOR DIS- POSAL OF FLAMMABLE
MAT'S. CONTAMINATED ABSORBENT MAY BE DISPOSED IN A HAZARDOUS
WASTE LANDFILL.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:NITRIC ACID, A509 212 002
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:NITRIC ACID (SARA 302/313) (CERCLA)
CAS:7697-37-2
RTECS #:QU5775000
Fraction by Wt: 69-71%
OSHA PEL:2 PPM
ACGIH TLV:2 PPM/4 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER. LD50: (ORAL,RAT) >90 ML/KG
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 29-31%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 2
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: CAUSES SEVERE BURNS. MAY
CAUSE IRREVERSIBLE EYE INJURY. SKIN: MAY CAUSE SEVERE IRRITATION.
CAUSES BURNS. MAY CAUSE DEEP PENETRATING ULCERS OF SKIN. INGESTION:
CAUSES GASTROINTESTINAL TRACT BURNS. MAY CAUSE PERFORATION OF
DIGESTIVE TRACT. INHALATION: MAY BE FATAL. EFFECTS MAY BE DELAYED.
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: MAY CAUSE IRRITATION OF RESPIRATORY
TRACT WITH BURNING PAIN IN NOSE & THROAT, COUGHING, WHEEZING,
SHORTNESS OF BREATH & PULMONARY EDEMA. CHRONIC: REPEATED INHALATION
MAY CAUSE CHRONIC BRONCH ITIS. REPEATED EXPOSURE MAY CAUSE EROSION
OF TEETH. TARGET ORGANS: NONE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR @ LST 15 MINS, OCCASNLY
LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. DO NOT ALLOW VICTIM
TO RUB/KEEP EYES CLSD. SKIN: GET MED AID IMMED. FLUSH W/PLENTY OF
SOAP & WA TER FOR @ LST 15 MINS WHILE REMOVING CONTAMD CLTHG &
SHOES. WASH CLTHG BEFORE REUSE. INGEST: DO NOT INDUCE VOMIT. IF
VICTIM IS CONSCIOUS & ALERT, GIVE 2-4 CUPFULS OF MILK/WATER. NEVER
GIVE (SUPDAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:SUBSTANCE IS NONCOMBUSTIBLE; USE AGENT MOST
APPROPRIATE TO EXTINGUISH SURROUNDING FIRE.
Fire Fighting Procedures:NIOSH APPRVD SCBA & FULL PROT EQUIP . STRONG
OXIDIZER. CONT W/COMBUST MATLS MAY CAUSE FIRE. USE WATER SPRAY TO
KEEP FIRE EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:SUBSTANCE IS NONCOMBUSTIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROT EQUIP AS INDICATED.
ABSORB SPILL W/INERT MATERIAL, (E.G., DRY SAND/EARTH), THEN PLACE
INTO CHEMICAL WASTE CNTNR. NEUT SPILL W/SODIUM BICARBONATE. A VAPOR
SUPPRESSING FOAM MAY BE USED TO REDUCE VAPORS.
Neutralizing Agent:SODIUM BICARBONATE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A TIGHTLY CLOSED CONTAINER.
STORE IN A COOL, DRY, WELL-VENTILATED AREA AWAY FROM INCOMPATIBLE
SUBSTANCES.
Other Precautions:USE W/ADEQUATE VENTILATION. DO NOT GET IN EYES, ON
SKIN, OR ON CLOTHING. KEEP CONTAINER TIGHTLY CLOSED. DO NOT INGEST
OR INHALE. DANGER! STRONG OXIDIZER. CONT W/OTHER MATL MAY CAUSE A
FIRE. CORROSIVE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
29CFR 1910.134. ALWAYS USE A NIOSH-APPROVED RESPIRATOR WHEN
NECESSARY.
Ventilation:USE WITH ADEQUATE VENTILATION.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . WEAR
APPROP CLOTHING TO PREVENT SKIN EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE CONTAMD
CLOTHING & WASH BEFORE REUSE.
Supplemental Safety and Health
FIRST AID PROC: ANYTHING BY MOUTH TO UNCON PERSON. GET MED AID IMMED.
INHAL: REMOVE TO FRESH AIR IMMED. IF NOT BRTHG, GIVE ARTF RESP. IF
BRTHG IS DFCLT, GIVE OXYG. GET MED AID. NOTE TO PHYS: TREAT SYM
PTOMATICALLY & SUPPORTIVELY. EYE PROT: & FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:187F,86C
Melt/Freeze Pt:M.P/F.P Text:-44F,-42C
Vapor Pres:6.8
Spec Gravity:1.50
pH:1.0
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR TO YELLOW LIQUID. STRONG ODOR, ACRID ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTS W/OVER 150 CHEM COMBINATIONS. REFER TO NFPA FIRE PROT GUIDE FOR
SPECIFICS. REACTS EXPLO W/ORG MATLS & COMBUST.
Stability Condition to Avoid:DECOMPOSES WHEN IN CONTACT W/AIR, LIGHT,
OR ORGANIC MATTER. HIGH TEMPS, COMPAT MATLS, MOISTURE, REDUCING
AGENTS.
Hazardous Decomposition Products:NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE, AND LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:PAINT, RUBBER BASE, MASONRY
CAGE:33200
CAGE:33200
============= Composition/Information on Ingredients =============
Ingred Name:PIGMENTS
Fraction by Wt: 26.2%
Other REC Limits:NOT HAZARDOUS
Ingred Name:VEHICLE
Fraction by Wt: 01.7%
Other REC Limits:NOT HAZARDOUS
Ingred Name:AROMATIC AND ALIPHATIC HYDROCARBONS (SOLVENTS)
Fraction by Wt: 42.1%
OSHA PEL:500 PPM
ACGIH TLV:500 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NK:Explanation of Carcinogenicity:NONE
OF THE CHEMICALS IN THIS PRODUCT IS LISTED BY IARC, NTP OR OSHA AS
A CARCINOGEN.
Effects of Overexposure:EYE: SEVERE EYE IRRITATION SKIN: CAUSES DRYING
OF THE SKIN. INHALATION: EXCESSIVE INHALATION CAUSES HEADACHE,
DIZZINESS, NAUSEA.
======================= First Aid Measures =======================
First Aid:EYE: EYE CONTACT FLUSH WITH WATER. SKIN: SKIN CONTACT WASH
WITH MILD SOAP AND WATER AND APPLY SKIN CREAM. INHALATION: REMOVE
TO FRESH AIR AND CALL PHYSICIAN. INGESTION: NK
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:102F 39C
Lower Limits:0.9
Upper Limits:7.0
Extinguishing Media:USE FOAM, CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:TREAT AS CLASS B FIRE.
Unusual Fire/Explosion Hazard:VAPORS MAY FORM EXPLOSIVE MIXTURES WITH
AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR A RESPIRATOR. FLUSH WITH WATER INTO
RETAINING AREA OR CONTAINER. AVOID EXPOSURE TO SPARKS, FIRE OR HOT
METAL SURFACES.
Neutralizing Agent:NONE APPLICABLE FOR THIS MATERIAL
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS, OPEN
FLAME. USE WITH ADEQUATE VENTILATION. AVOID PROLONGED OR REPEATED
SKIN CONTACT.
Other Precautions:COMBUSTIBLE LIQUID
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELF CONTAINED NIOSH APPROVED RESPIRATOR IF TLV
IS EXCEEDED.
Ventilation:LOCAL EXHAUST MAY BE REQUIRED IF WORK AREA IS NOT VENTED.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH.
Supplemental Safety and Health
DO NOT ALLOW STORAGE FOR PROLONGED PERIODS IN NON-INSULATED TRAILERS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:240F,116C
Vapor Pres:6@68F
Vapor Density:3.7
Spec Gravity:1.31
Evaporation Rate & Reference:(N BU AC=1) 0.9
Solubility in Water:VERY SLIGHT
Appearance and Odor:OPAQUE LIQUID. PETROLEUM DISTILLATE ODOR.
Percent Volatiles by Volume:56
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN LANDFILL, INCINERATION UNDER SAFE
AND SUPERVISED CONDITIONS.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: SUPERIOR HOUSE AND TRIM GLOSS PAINT, 10-101
Cage: 75734
=======================================================
Contractor Summary
=======================================================
Cage: 75734
Cage: 55652
=======================================================
Ingredients
=======================================================
Cas: 26530-20-1
RTECS #: NX8156900
(ORAL RAT) 550 MG/KG. %: 0.28-0.33
% Wt: <0.33
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 1335-30-4
% Wt: 0-13.2
OSHA PEL: 10 MG/M3 TDUST (MFR)
ACGIH TLV: 10 MG/M3 TDUST (MFR)
------------------------------
Cas: 1317-65-3
RTECS #: EV9580000
% Wt: 0-19.0
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST; 9495
------------------------------
Cas: 8001-26-1
RTECS #: OI9690000
% Wt: 3.6-5.4
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 8052-41-3
RTECS #: WJ8925000
% Wt: 17.3-21
OSHA PEL: 500 PPM
ACGIH TLV: 100 PPM; 9495
------------------------------
% Wt: <45.7
OSHA PEL: 500 PPM
ACGIH TLV: 100 PPM; 9495
-----------------------------
Cas: 13463-67-7
RTECS #: XR2275000
% Wt: 0-22.5
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST; 9495
------------------------------
Cas: 1314-13-2
RTECS #: ZH4810000
% Wt: 0-5.0
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST; 9495
------------------------------
Cas: 14808-60-7
RTECS #: VV7330000
OSHA PEL: SEE TABLE Z-3
ACGIH TLV: 0.1 MG/M3 RDUST;9495
------------------------------
RTECS #: 9999999VO
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
KIDNEY EFTS OBSERVED IN MALE RATS HAVE
-----------------------------
WORKPLACE. SKIN:PRLNGD/RPTD CNTCT CAN CAUSE
-----------------------------
REDNESS, TEARING, BLURRED VISION. INGEST:CAN
-----------------------------
ASPIRATION OF MATERIAL INTO THE LUNGS
-----------------------------
TOXICOLOGICAL INFORMATION: CRYSTALLINE
-----------------------------
WOULD NOT NORM BE ENCOUNTERED WHEN
-----------------------------
-----------------------------
HEAD BELOW HIPS TO PVNT ASPIR OF LIQ INTO
-----------------------------
-----------------------------
OBSERVE PRECS FOR VOLATILE, COMBUST
-----------------------------
-----------------------------
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50: (ORAL, RAT) >5 G/KG.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: INHAL:EXCESSIVE INHALATION OF VAPORS CAN CAUSE NASAL AND
RESPIRATORY IRRITATION, DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, HEADACHE. HIGH
VAPOR CONCENTRATIONS MAY RESULT IN CNS DEPRESSION. LABORATORY ANIM AL STUDIES
HAVE SHOWN THAT PROLONGED AND REPEATED INHALATION EXPOSURE TO LIGHT
HYDROCARBON VAPORS IN (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: SILICA, CRYSTALLINE-QUARTZ:IARC MONOGRAPHS,
SUPPLEMENT. VOL 7, PG 341, 1987: GROUP 2A. NTP 7TH ANNUAL REPORT ON
Signs And Symptions Of Overexposure: HLTH HAZ:SAME NAPHTHA BOILING RANGE AS
THIS PROD CAN PRDC ADVERSE KIDNEY EFTS IN MALE RATS. HOWEVER, THESE EFTS WERE
NOT OBSERVED IN SIMILAR STUDIES W/FEMALE RATS & MALE & FEMALE MICE
& IN LIM STUDIESW/OTHER ANIMAL SPECIES. ADDNLY, IN NUMBER OF HUMAN
STUDIES, THERE WAS NO CLINICAL EVIDENCE OF SUCH EFFECTS AT
Medical Cond Aggravated By Exposure: HIGH VAPOR CONCENTRATIONS (GREATER THAN
APPROXIMATELY 1000 PPM) ARE IRRIT TO EYES & THE RESPIRATORY TRACT, MAY
CAUSE HEADACHES & DIZZINESS, ARE ANESTHETIC, AND MAY HAVE OTHER CNS EFTS
INCLUDING DEATH.
First Aid: INHAL:REMOVE VICTUM TO FRESH AIR & PROVIDE OXYGEN IF BREATHING
IS DIFFICULT. IF BRTHG STOPS, BEGIN ARTF RESP & SEEK IMMED MED ATTN.
SKIN:REMOVE CONTAMD CLTHG/SHOES. FLUSH W/H*2O. FOLLOW BY WASHING W/S OAP
& H*2O. IF IRRIT OCCURS, GET MED ATTN. DO NOT REUSE CLTHG UNTIL CLEANED.
EYE:IF SPLASHED IN EYES, FLUSH W/CLEAN H*2O FOR AT LEAST 15 MIN/UNTIL IRRIT
SUBSIDES. IF IRRIT PERSISTS, CALL MD.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: ELIM ALL IGNIT SOURCES (FLARES, FLAMES INCLUDING
PILOT LTS, ELEC SPARKS). RECOVER FREE PROD, ADD SAND, EARTH/OTHER SUITABLE
ABSORB TO SPILL AREA. MIN SKIN CNTCT. VENT CONFINED SPACES. KEEP PROD OUT OF
SEWERS & WATERCOURSES BY DIKING OR
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF PRODUCT IN ACCORDANCE WITH APPLICABLE LOCAL,
COUNTY, STATE AND FEDERAL REGULATIONS.
Handling And Storage Precautions: NONE SPECIFIED BY MANUFACTURER.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: 104F,40C
Lower Limits: 0.9%
Upper Limits: 6.0%
Extinguishing Media: USE DRY CHEM, FOAM/CARBON DIOXIDE. H*2O MAY BE INEFT, BUT
H*2O SHOULD BE USED TO KEEP FIRE-EXPOSED CNTNR COOL.(SUPDAT)
Fire Fighting Procedures: USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP (FP
N). H*2O MAY BE UNSUITABLE AS EXTING MEDIA, BUT HELPFUL IN KEEPING ADJACENT
CNTNRS COOL.
Unusual Fire/Explosion Hazard: AVOID SPREADING BURNING LIQ W/H*2O USED FOR
COOLING. VAPS ARE HVR/AIR & MAY TRAVEL ALONG THE GROUND/BE MOVED BY
VENTILATION & IGNITED BY HEAT, PILOT (SUPDAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: THE USE OF RESPIRATORY PROTECTION DEPENDS ON VAPOR
CONCENTRATION ABOVE THE TIME WEIGHTED TLV: USE NIOSH/MSHA APPROVED
RESPIRATOR.
Ventilation: PROVIDE SUFFICIENT MECHANICAL (GENERAL) AND/OR LOCAL EXHAUST
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: DO NOT EAT, DRINK OR SMOKE WHILE USING THIS PRODUCT.
THOROUGHLY WASH HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health: EXTING MEDIA:IF LEAK/SPILL HAS IGNITED, USE
H*2O SPRAY TO DISPERSE VAPS & TO PROTECT MEN ATTEMPTING TO STOP LEAK. MIN
BRTHG GASES, VAPS, FUMES/DECOMP PROD. EXPLO HAZ:LIGHT, OTHER FLAME &
IGNIT SOURCES AT LOCATIONS DIST FROM HNDLG POINT. NEVER USE WELDING/CUTTING
TORCH ON/NEAR CNTNR (EVEN EMPTY) BECAUSE VAP MAY IGNITE.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >368F,>187C
Vapor Pres: 2 @ 20F
Vapor Density: 4.9
Spec Gravity: 1.25
Evaporation Rate & Reference: 0.1 (BUTYL ACETATE = 1)
Appearance and Odor: VISCOUS LIQUID, HYDROCARBON ODOR.
Percent Volatiles by Volume: 47.04
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: THIS PRODUCT IS INCOMPATABLE WITH STRONG OXIDIZING AGENTS,
STRONG ACIDS OR BASES AND SELECTED AMINES.
Hazardous Decomposition Products: THERMAL DECOMPOSITION IN THE PRESENCE OF AIR
MAY YIELD CARBON MONOXIDE AND/OR CARBON DIOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: SUPERIOR HOUSE AND TRIM GLOSS PAINT, 10-101
Cage: 75734
Company Name: DURON INC
Street: 10406 TUCKER ST
Zipcode: 20705-2297
Label Required IND: Y
Date Of Label Review: 10/02/1995
Status Code: C
Label Date: 10/02/1995
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Severe
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: ACUTE: AVOID EYE CONTACT. INHAL:EXCESSIVE INHALATION OF
VAPORS CAN CAUSE NASAL AND RESPIRATORY IRRITATION, DIZZINESS, WEAKNESS,
FATIGUE, NAUSEA, HEADACHE. HIGH VAPOR CONCENTRATIONS MAY RESULT IN CNS D
EPRESSION. INGESTION:CAN CAUSE GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING
AND DIARRHEA. ASPIRATION HAZARD. SKIN:CAN CAUSE MODERATE IRRITATION,
DEFATTING AND/OR DERMATITIS. EYE:CAN CAUSE IRRITATION, REDNESS, TEARING AND
BLURRED VISION. CHRONIC:CANCER HAZARD. CONTAINS CRYSTALLINE SILICA QUARTZ
WHICH IS LISTED AS AN ANIMAL LUNG CARCINOGEN. OVEREXPOSURE MAY CAUSE ADVERSE
KIDNEY AND LUNG EFFECTS.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ENAMEL,ALKYD,GLOSS 15045
CAGE:60189
CAGE:60189
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA (PETROLEUM SPIRITS OR BENZIN)
CAS:8030-30-6
RTECS #:SE7555000
Fraction by Wt: 50.8%
OSHA PEL:100 PPM
===================== Hazards Identification =====================
Effects of Overexposure:IRRITATION OF EYES AND SKIN.IRRITATION OF
RESPIRATORY TRACT. HEADACHE OR DIZZY.
======================= First Aid Measures =======================
First Aid:SKIN/EYES:FLUSH WITH PLENTY OF WATER. INHAL:MOVE TO FRESH
AIR. IF IRRITATION PERSISTS,CALL DR.
===================== Fire Fighting Measures =====================
Flash Point:40.6/105 TCC
Lower Limits:0.9
Upper Limits:6.0
Extinguishing Media:CLASS B EXTINGUISHERS (CO*2,DRY CHEM.OR FOAM)
Fire Fighting Procedures:USE WATER TO COOL CLOSED CONTAINERS & PREVENT
AUTOIGNITION
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED AND
ISOLATE FROM SOURCES OF IGNITION.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION(FLAMES,HOT
SURFACES,ELECTRICAL,STATIC OR FRICTIONAL SPARKS).AVOID BREATHING OF
VAPORS.VENTILATE AREA. REMOVE WITH NON-SPARKING TOOLS AND INERT
ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE AT ELEVATED TEMP.KEEP
AWAY FROM OPEN FLAMES AND SPARKS.
Other Precautions:DO NOT TAKE INTERNALLY.CONTAINERS SHOULD BE GROUNDED
WHEN POURING.AVOID PROLONGED OR REPEATED CONTACT WITH SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:BUREAU OF MINES APPROVED CHEM/MECH FILTER
RESPIRATOR
Ventilation:LOCAL EXHAUST
Other Protective Equipment:PREVENT PROLONGED SKIN CONTACT WITH
CONTAMINATED CLOTHING
Supplemental Safety and Health
CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.DO NOT APPLY
TO HOT SURFACES.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:157.2/315
Vapor Pres:1
Vapor Density:4.7
Spec Gravity:0.92
Evaporation Rate & Reference:BUAC=1: 0.15
Solubility in Water:0
Appearance and Odor:BLUE LIQUID,MILD ALIPHATIC ODOR.
Percent Volatiles by Volume:61
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO,CO*2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL,STATE AND
FEDERAL REGULATIONS.DO NOT INCINERATE CLOSED CONTAINERS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:COATING, EPOXY-POLYAMIDE CLEAR COMP 2
Kit Part:Y
CAGE:GO043
CAGE:29477
CAGE:GO043
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 15%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:N-BUTYL ALCOHOL (SARA III)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 15%
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL ACETATE (SARA III)
CAS:141-78-6
RTECS #:AH5425000
Fraction by Wt: 29%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 19%
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-BUTOXYETHANOL
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 2%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
Ingred Name:OTHER PREC: FROM HEAT, SPARKS, OPEN FLAME. USE ONLY W/ADEQ
VENT. AVOID CONT W/EYES & SKIN. DO NOT TAKE (SEE ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: INTERNALLY. EMPTY CNTNRS MAY CONTAIN PROD RESIDUE
INCL FLAM/EXPLO VAPS. DO NOT CUT, PUNCTURE/WELD ON (SEE ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: OR NEAR CNTNR. ALL LABEL WARNINGS MUST BE OBSERVED
UNTIL THE CNTNR HAS BEEN CLEANED OR RECONDITIONED.
RTECS #:9999999ZZ
Ingred Name:SUP DAT:CNS,THE HEMATOPOIETIC TISSUES,THE BLOOD,THE KIDNEYS
& THE LIVER,ASSOC W/THE ADMINISTRATION OF ETHYLENE (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:GLYCOL MONOBUTYL ETHER (EGBE) & ETHYLENE GLYCOL
MONOBUTYL ETHER ACETATE (EGBEA).INGEST OF LG QTYS MAY RSLT(ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:IN RED BLOOD CELL HEMOLYSIS.CHRONIC:RPTD/PRLNG
OVEREXPO TO VAPS MAY AFFECT CNS & CAUSE RESP IRRI & MAY (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:CAUSE LVR & KDNY DMG.A CASE EFT SHOWED ACTIVE LVR &
KDNYDYSFUNCTION AT EXTREM HIGH LVLS TO XYLENE & (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:TOLUENE.RPTS HAVE ASSOC RPTS.PRLNG OVEREXP TO
SOLVENTS W/PERM BRAIN & NERV SYS DMG.INTENTIONAL MISUSE BY (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:DELIB CONC & INHAL CONTENTS MAY BE HARMFL OR
FATAL.SKIN ABSORPTION:MAY BE HARMFUL IF ABSORBED THRU SKIN. (ING
15)
RTECS #:9999999ZZ
Ingred Name:ING 14: RPTD/PRLNG SKIN CONT MAY CAUSE DRYING & DEFAT,
WHICH MAY LEAD TO DERMAT.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL OF VAPS/SPRAY MISTS CAN
CAUSE IRRI OF RESP TRACT/ACUTE NERV SYS DEPRESS CHARA BY
HDCH,DIZZ,STAG GAIT,CONFUSN,UNCON/COMA.OVEREXP CAN CAUSE EYE & SKIN
IRRI.EYE CONT W/LIQ MAY CAUSE SEV IRRI. INGEST:MAY BE HARMFUL IF
SWALLOWD.CAN CAUSE GI IRRI,NAUS,DIARR & POSS VOMIT.ASPIR IN LUNGS
CAN CAUS(SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:PNEUM WHICH CAN BE FATAL.BUTYL
CELLOSOLVE (2-BUTOXYETHANOL) IN UNDILUTED FORM IS MOD TOX IF INGEST
& WILL PENETRATE SKIN READILY.FREQ/WIDESPREAD CONT MAY RSLT IN THE
ABSORPTION OF POTENTIALLY HARMFUL AMTS OF MATL.BUTYL CELLOSOLVE
HAS BEEN KNOWN TO INCREASE THE OSMOTIC FRAGILITY OF BLOOD CELLS
IN(SEE SUPP DATA)
Medical Cond Aggravated by Exposure:PREEXISTING SKIN, EYE, AND
RESPIRATORY DISORDERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. IF BRTHG STOPPED, GIVE
MOUTH-TO-MOUTH RESUSCITATION & KEEP WARM & QUIET. IF BRTHG DFCLT,
GIVE OXYGEN. GET MD IMMED. EYES: FLUSH IMMED WITH COPIOUS QTYS OF
WATER FOR 15 MIN & TAKE TO MD FOR DEFINITIVE MED TRTMT. SKIN:
REMOVE CONTAM CLTHG & WASH AFFECTED AREA WITH SOAP & WATER. IF
IRRIT PERSISTS, SEE MD. INGEST: DO NOT INDUCE VOMITING. CALL MD OR
POIS CTL CTR IMMED.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:34.0F,1.1C
Lower Limits:SEE INGRED
Extinguishing Media:DRY CHEMICAL, CO*2 OR WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD PRESS DEMAND SCBA &
FULL PROT EQUIP . REMOVE SOURCES OF IGNIT. USE H*2O TO COOL UNRPTRD
CLSD CNTNRS TO PVNT PRESS (SEE SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLOSED. ISOLATE FROM
HEAT, ELEC EQUIP, SPARKS, OPEN FLAME. CLOSED CNTNRS MAY EXPLODE
WHEN EXPOSED TO EXTREME HEAT. DO NOT APPLY TO HOT SURF.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT (FLAMES, HOT
SURFACES & ELEC, STATIC/FRICTION SPARKS). AVOID BRTHG VAPS. VENT
AREA. REMOVE W/INERT ABSORB & NON-SPARKING TOOLS. TRANSFER TO
APPROP CNTNR FOR DISP. KEEP OUT OF SEWERS, STORM DRAINS, SURFACE
WATER & SOIL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. STORE LARGE
QUANTITIES IN BUILDING DESIGNED & PROTECTED FOR STORAGE OF NFPA
CLASS 1B FLAMMABLE LIQUIDS.
Other Precautions:CNTNRS SHOULD BE GROUNDED WHEN POURING. AVOID FREE
FALL OF LIQ IN EXCESS OF A FEW INCHES. DO NOT FLAME CUT, BRAZE OR
WELD WITHOUT NIOSH/MSHA APPRVD RESP OR APPROP VENT. WARNING: FLAM.
VAP HARMFUL. MAY CAUSE IRRIT. KEEP AWAY (SEE INGRED 6)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:OUTDOOR/OPEN AREAS: NIOSH/MSHA APPRVD MECH
FILTER RESP TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY.
RESTRICTED VENT AREAS: CHEM-MECH FILTERS TO REMOVE A COMBINATION OF
PARTICULATE & VAP. CONFINED AREAS: AIR LINE TYPE RESP OR HOODS.
Ventilation:GEN DILUTION/LOCAL EXHST VENT TO KEEP TLV/LEL < LIM &
REMOVE DECOMP PRODS DURING WELDING/FLAME CUTTING.
Other Protective Equipment:PREVENT PROLONGED SKIN CONTACT TO
CONTAMINATED CLOTHING.
Work Hygienic Practices:WASH HANDS FREQUENTLY AND THOROUGHLY DURING
CONTACT WITH MATERIAL AND AT END OF WORK SHIFT .
Supplemental Safety and Health
FIRE FIGHT PROC:BUILDUP & POSS AUTO-IGNIT/EXPLN WHEN EXPOSD TO EXTRM
HEAT.FOG NOZZLES PREF IF H*2O IS USED.EFTS OF OVEREXP:SOME
ANIMALS.IN HMNS,EVEN AT EXPOS LVLS AS HIGH AS 200 PPM,THESE BLOOD
EFTS D ID NOT OCCUR AT ALL (MFR).ANIMAL STUDIES HAVE CLEARLY
DEMONSTRATED DOSE-RELATED ADVERSE EFFECTS ON THE (SEE INGRED 9)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:175F,79C
Vapor Pres:SEE INGRED
Vapor Density:>AIR
Spec Gravity:0.89
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:80.7
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:ACRID FUMES, SMOKE AND CARBON MONOXIDE
AND/OR CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:03GY061CAT GRAY 16440 CATALYST
Kit Part:Y
CAGE:FO688
CAGE:FO688
CAGE:33461
============= Composition/Information on Ingredients =============
Ingred Name:2-ETHOXYETHYL ACETATE (CELLOSOLVE ACETATE) (EGEEA)
CAS:111-15-9
RTECS #:KK8225000
Fraction by Wt: 10%
OSHA PEL:S,100 PPM
ACGIH TLV:S, 5 PPM; 9192
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 5%
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 5%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 50%
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ALIPHATIC ISOCYANATE
CAS:28182-81-2
Fraction by Wt: 30%
Ingred Name:1,6-DIISOCYANATOHEXANE (HEXAMETHYLENE DIISOCYANATE)
CAS:822-06-0
RTECS #:MO1740000
Fraction by Wt: 0.7-1.6%
Other REC Limits:0.02 PPM CEILING
ACGIH TLV:0.005 PPM; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:VAPORS ARE IRRITATING. ISOCYANATE IS
SENSITIZING;POSSIBLY CAUSING REACTIONS WITH A SECOND EXPOSURE WELL
BELOW TLV. 2-ETHOXYETHYL ACETATE IS ABSORBED BY THE SKIN,POSSIBLY
CAUSING LIVER,KIDNEY OR REPROD UCTIVE EFFECTS.
Effects of Overexposure:EYE:IRRITATION,REDNESS,SWELLING.
SKIN:IRRITATION.PROLONGED CONTACT MAY CAUSE DRYING,CRACKING OF
SKIN. INHALED:IRRITATION & CENTRAL NERVOUS SYSTEM
DEPRESSION;HEADACHE,DIFFICULT BREATHING,DIZZINESS,CONF USION.
INGESTED:G/I IRRITATION.
Medical Cond Aggravated by Exposure:ASTHMA AND OTHER RESPIRATORY
DISORDERS,SKIN ALLERGIES,ISOCYANATE SENSITIZATION.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH WITH WATER 15 MIN. SKIN:REMOVE CONTAMINATED
CLOTHING. WASH WITH SOAP & WATER. LAUNDER CLOTHING BEFORE REUSE.
INHALED:REMOVE FROM EXPOSURE. ASMATIC SYMPTOMS MAY DEVELOP OR BE
DELAYED. GET MED ICAL ATTENTION AS NEEDED. INGESTED:DO NOT INDUCE
VOMITING(ASPIRATION HAZARD). GET IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:23F/-5C
Extinguishing Media:FOAM,CARBON DIOXIDE,DRY CHEMICAL,WATER FOG
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS. USE
WATER SPRAY TO COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. EXPOSURE TO DECOMPOSITION PRODUCTS MAY BE
HEALTH HAZARD PRODUCING DELAYED SYMPTOMS.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE UNNECESSARY PERSONNEL. ELIMINATE
IGNITION SOURCES. VENTILATE AREA. ABSORB ON INERT MATERIAL. STORE
IN CLOSED CONTAINERS PENDING DISPOSAL.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA. STORE TIGHTLY CLOSED AND FREE OF IGNITION SOURCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH RESPIRATOR WITH ORGANIC VAPOR
CARTRIDGE OR SUPPLIED AIR RESPIRATOR IF EXPOSED ABOVE TLV'S.
EXCEPT:USE SUPPLIED AIR RESPIRATOR IF OVER TLV OF DIISOCYANATE.
Ventilation:USE EXHAUST TO MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment:LONG SLEEVE,LONG LEG WORK CLOTHING. LAUNDER
CONTAMINATED CLOTHS BEFORE REUSE.
Work Hygienic Practices:USE VERY STRICT CHEMICAL HYGIENE PRACTICE. TAKE
UNUSUAL PRECAUTIONS TO PREVENT CONTACT WITH SENSITIZING
DIISOCYANATES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:175-313F
Vapor Density:>AIR
Spec Gravity:0.92 (CALC.)
Evaporation Rate & Reference:2.3 (BUAC)
Appearance and Odor:AMBER LIQUID,SOLVENT ODOR
Percent Volatiles by Volume:74.9
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER,AMINES,STRONG BASES,ALCOHOLS,METAL COMPOUNDS,SURFACE ACTIVE
MATERIALS
Stability Condition to Avoid:HIGH TEMPERATURES,MOISTURE
Hazardous Decomposition Products:NORMAL PRODUCTS OF COMBUSTION PLUS
CYANIDES AND ISOCYANATES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W FEDERAL,STATE,LOCAL REGULATIONS.
DO NOT INCINERATE CLOSED CONTAINERS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:2,3-DIMETHYLBUTANE, O-730
CAGE:84898
CAGE:84898
CAGE:8Y898
============= Composition/Information on Ingredients =============
Ingred Name:BUTANE, 2,3-DIMETHYL-; (2,3-DIMETHYLBUTANE); (DIISOPROPYL)
CAS:79-29-8
RTECS #:EJ9350000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONT LENSES SHOULD NOT BE WORN IN LAB.
ALL CHEMS SHOULD BE CONSIDERED HAZ-AVOID DIRECT PHYSICAL CONT! CAN
CAUSE SKIN IRRITATION. CAN BE IRRITATING TO MUCOUS MEMBRANES. CAN
CAUSE EYE IRRITATION. CAN BE HARMFUL IF ABSORBED THORUGH THE SKIN,
INHALED AND SWALLOWED. ASSUME THIS CHEMICAL IS TOXIC AND USE (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:SPECIAL CARE TO AVOID CONTACT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:AN ANTIDOTE IS SUBSTANCE INTENDED TO COUNTERACT EFT OF POIS.
IT SHOULD BE ADMIN ONLY BY MD/TRAINED EMER PERS. MED ADVICE CAN BE
OBTAINED FROM POIS CTL CTR. EYES:FLUSH CONTINUOUSLY W/WATER FOR @
LST 15 MIN. SKIN:FLUSH W/WATER FOR 15-20 MIN.IF NO BURNS HAVE
OCCURRED-USE SOAP & WATER TO CLEANSE. INHAL:REMOVE TO FRESH AIR.
ADMIN OXYG IF PATIENT IS HAVING DFCLTY BRTHG. IF PATIENT HAS
STOPPED (SUP DAT)
===================== Fire Fighting Measures =====================
Flash Point:-18F,-28C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER OR WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THIS IS A FLAMMABLE CHEMICAL.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR APPROPRIATE OSHA-REGULATED
EQUIPMENT. VENTILATE AREA. ABSORB ON VERMICULITE OR SIMILAR
MATERIAL. SWEEP UP AND PLACE IN AN APPROPRIATE CONTAINER. HOLD FOR
DISPOSAL. WASH CONTAMINATE D SURFACES TO REMOVE ANY RESIDUES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE APPROP OSHA/MSMA APPRVD SFTY
EQUIP. AVOID CONT W/SKIN, EYES & CLTHG. KEEP TIGHTLY CLSD & STORE
IN COOL, DRY PLACE. STORE ONLY W/COMPATIBLE CHEMS.
Other Precautions:PERSONS NOT SPECIFICALLY & PROPERLY TRAINED SHOULD
NOT HNDL CHEM/ITS CNTNR. FURNISHED FOR LAB USE ONLY! MAY NOT BE
USED AS DRUGS, COSMETICS, AGRICULTURAL/PESTICIDAL PRODS, FOOD
ADDITIVES/AS HOUSEHOLD CHEMICALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:THIS CHEMICAL SHOULD BE HANDLED ONLY IN A HOOD.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC:BRTHG ADMIN ARTF RESP. IF EXHIBITING SIGNS OF SHOCK-KEEP
WARM & QUIET. GET MED ATTN IF NEC. IF IN CARDIAC ARREST ADMIN CPR.
CONTINUE LIFE SUPPORTING MEASURES UNTIL MED ASSISTANCE HAS AR
RIVED. INGEST:CONT MD IMMED . EYEPROT:FULL LENGTH FACE SHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:136F,58C
Melt/Freeze Pt:M.P/F.P Text:-200F,-129C
Vapor Density:0.662
Solubility in Water:INSOL (IMMISCIBLE)
Appearance and Odor:COLORLESS LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
FLAMMABLE. INCOMPATIBLE WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:DECOMPOSITION LIBERATES TOXIC FUMES.
DECOMPOSITION PRODUCTS ARE CORROSIVE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SODIUM PHOSPHATE, TRIBASIC SX0730
CAGE:OAL61
CAGE:1U692
CAGE:OAL61
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM PHOSPHATE, TRIBASIC(SARA III)
CAS:10101-89-0
RTECS #:TC9575000
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:EYES:MAY CAUSE BURNS. SKIN: MAY CAUSE IRRIT.
INH OF DUST: IRRIT OF UPPER RESPIRATORY TRACT.
======================= First Aid Measures =======================
First Aid:EYE OR SKIN: FLUSH W/WATER IMMED. DUST INH: REMOVE T FRESH
AIR. GET PROMT MEDICAL ATTN FOR ALL CASES OF OVEREXPOSURE.
================== Accidental Release Measures ==================
Spill Release Procedures:TAKE UP & CONTAINERIZE FOR PROPER DISPOSAL
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MFR RECM DUST RESPIRATOR IF NEC FOR EXCESS DUST.
NIOSH/MSHA APPRVD.
Ventilation:EXHAUST VENTILATION PREFERRED.
Supplemental Safety and Health
PORDUCT IS TYPE 2 UNDER THE SPEC.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.62
Solubility in Water:APPRECIABLE
Appearance and Odor:COLORLESS, ODORLESS CRYSTALS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS
Stability Condition to Avoid:MATRL IS STRONG CAUSTIC. CONTACT W/STRONG
ACID PROD HEAT.
Hazardous Decomposition Products:THERMAL DECOMP PRODUCES TOXIC
PHOSPHORUS OXIDE FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IAW FED,STATE & LOCAL CODES.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:8082730, SPECIALTY INK & PRODUCTS:8635, BRITE BLUE
CAGE:DO804
CAGE:DO804
CAGE:38360
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2-BUTOXY-; (ETHYLENE GLYCOL MONOBUTYL ETHER)
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 40-60%
OSHA PEL:50 PPM, S
ACGIH TLV:25 PPM, S
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: SEV IRRIT, REDNESS,
TEARING. BLURRED VISION. SKIN: MOD IRRIT, DEFAT, DERM. INHAL:
IRRIT, DIZZ, WEAKNESS, FATG, NAUS, HDCH. INGEST: IRRIT, NAUS,
VOMIT, DIARR. CHRONIC: HAS BEEN REPORTED TO CAUSE ANEMIA, LIVER
ABNORMS, KIDNEY DMG, LUNG DMG & BLOOD ABNORMS IN ANIMALS. SKIN
ABSORP MAY POTNLY(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: CONTRIBUTE TO OVERALL EXPOS TO MATL.
APPROP MEASURES SHOULD BE TAKEN TO PVNT ABSORP SO PEL/TLV IS NOT
INVALID. ANIMAL STUDIES HAVE CLEARLY DEMONSTRATED DOSE-RELATED
ADVERSE EFTS ON CNS, HEMA TOPOIETIC TISS, BLOOD, KIDNEY & LIVER
ASSOC W/ADMIN OF ETHYLENE GLYCOL MONOBUTYL ETHER(EGBE).(EXTRACTED
FROM (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/WATER FOR AT LEAST 15 MINS. CALL MD IMMED. SKIN:
WASH W/SOAP & WATER. LAUNDER CONTAMD CLTHG BEFORE REUSE. SKIN: WASH
W/SOAP & WATER. LAUNDER CONTAMD CLTHG BEFORE REUSE. GET MED ATTN.
INHA L: REMOVE TO FRESH AIR. IF BRTHG IS DIFFICULT GET MED ATTN
IMMED. INGEST: IF EMPLOYEE IS CONSCIOUS, GIVE TWO GLASSES OF WATER
& INDUCE VOMITING. GET MED ATTN IMMEDIATLEY.
===================== Fire Fighting Measures =====================
Flash Point:150F,66C
Extinguishing Media:DRY CHEMICAL, CO*2, ALCOHOL FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:VAPORS ARE HVR/THAN AIR & MAY TRAVEL
ALONG THE GROUND AND MAY BE IGNITED AT DISTANT LOCATIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIM ALL SOURCES OF IGNIT. ABSORB SPILLED MATL
W/VERMICULITE/FLOOR ABSORB. DISP OF CONTAMD MATLS PROPERLY. USE
TO OSHA STD: 29 CFR PAR T 1910.120 HAZ WASTE OPS & EMERGENCY
RESPONSE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CNTNRS OF MATL MAY BE HAZ WHEN
EMPTIED, SINCE EMPTIED CNTNRS RETAIN PRODUCT RESIDUES WHICH CAN
GENERATE VAPS W/IN FLAMMABLE LIMITS.
Other Precautions:THE USE OF HAZARDOUS CHEMICAL MAY REQUIRE
SUPPLEMENTAL VENT FOR THE PROT OF PERS & FOR CONTROLLING
FIRE/EXPLOS HAZ. A QUALIFIED INDEPENDENT TESTING CO CAN DETERMINE
IF EXISTING CONCS ARE W/IN ESTABISH ED RECOM/PERMISSIBLE EXPOS
LEVELS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUFFICIENT TO MAINTAIN OPERATOR EXPOSURE BELOW
APPLICBLE OCCUPATOINAL EXPOSURE STANDARDS. ENGINEERING OR
ADMINISTRATIVE CONTROLS OR NIOSH/MSHA RESPIRATORS CAN BE USED TO
REDUCE EXPOSURES. ENGINEERING CONTROLS ARE PREFERRED BY OSHA.
Ventilation:SUFFICIENT TO MAINTAIN OPERATOR EXPOSURE BELOW APPLICABLE
OCCUPATIONAL EXPOSURE STANDARDS.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP: DHHS(NIOSH) PUBLICATION NO. 90-118). WASTE DISP METH:
HAZ. CONTACT FEDERAL, STATE & LOCAL AUTHORITIES FOR DISPOSAL
INFORMATION. CONSULT 40CFR PART 261 IDENTIFICATION AND LISTING OF
HAZARDOUS WASTE. DISP OF I/A/W LOCAL, STATE & FEDERAL REGS.
================== Physical/Chemical Properties ==================
Evaporation Rate & Reference:MODERATE
Appearance and Odor:LIQUID OR SEMI-SOLID INK W/MILD SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT & FLAME.
Hazardous Decomposition Products:CO, CO*2.
==================== Disposal Considerations ====================
Waste Disposal Methods:UNDER THE RCRA, IT IS THE RESPONSIBILITY OF THE
GENERATOR OF THE WASTE TO DETERMINE AT THE TIME OF DISP, WHETHER
THE WASTE GENERATED MEETS FEDERAL/STATE HAZ WASTE CRITERIA. USES,
TRANSFORMATIONS, MIXS , PROCESSES, ETC, MAY RENDER RSLG MATL
(SUPDAT)
| 1 |
gloves_mandatory
|
=======================================================
Product ID: UH6800, WHITE, ULTRA-HIDE INTERIOR LATEX EGGSHELL (SUPDAT)
Cage: FO881
=======================================================
Contractor Summary
=======================================================
Cage: 01PD6
Cage: FO881
=======================================================
Ingredients
=======================================================
Cas: 1317-65-3
RTECS #: EV9580000
% Wt: 5-10
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST; 9495
------------------------------
Cas: 1332-58-7
RTECS #: GF1670500
% Wt: 1-5
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 2 MG/M3 TDUST; 9495
------------------------------
Cas: 66402-68-4
% Wt: 1-5
OSHA PEL: 10 MG/M3 (MFR)
ACGIH TLV: 5 MG/M3 (MFR)
------------------------------
Cas: 25265-77-4
RTECS #: UF6000000
(TEXANOL)
% Wt: 1-5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 13463-67-7
RTECS #: XR2275000
% Wt: 10-20
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST; 9495
------------------------------
Cas: 25067-01-0
% Wt: 10-20
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 7732-18-5
RTECS #: ZC0110000
% Wt: 10-20
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 7732-18-5
RTECS #: ZC0110000
% Wt: 30-40
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
LEAST 15 MINUTES. IF IRRITATION OR
-----------------------------
MEDICAL TREATMENT IMMEDIATELY.
-----------------------------
SURFACES. IF SUCH CONDITIONS CANNOT BE
-----------------------------
SPECIAL PROTECTION INFORMATION.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHALATION: IRRITATION OF RESPIRATORY TRACT. PROLONGED
INHALATION MAY LEAD TO MUCOUS MEMBRANE IRRITATION, COUGHING, RESPIRATORY
PROBLEMS, BRONCHITIS. SKIN CONTACT: IRRITATION OF SKIN. EYE CONTACT: IRR
ITATION OF EYES. INGESTION: MAY CAUSE NAUSEA, GASTRO-INTESTINAL DISTURBANCE.
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: EYE, SKIN, RESPIRATORY DISORDERS LUNG
DISORDERS.
First Aid: INHAL:REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
GET EMER MED ATTN. HAVE TRAINED PERSON GIVE OXYGEN IF NECESARY. GET MED HELP
FOR ANY BRTHG DIFFICULTY. REMOVE TO FRESH AIR IF INHAL CAUSES EYE WATERING,
HDCHS, DIZZ/OTHER DISCOMFORT. SKIN:FLUSH FROM SKIN W/H*2O. THEN WASH
THOROUGHLY W/SOAP & H*2O REMOVE CONTAMD CLTHG. WASH CONTAMD CLTHG BEFORE
RE-USE. EYE:FLUSH IMMED
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: COMPLY W/ALL APPLICABLE HLTH & ENVIRONMENTAL
REGS. ELIMINATE ALL SOURCES OF IGNITION. VENT AREA. EVACUATE ALL UNNECESSARY
PERSONNEL. PLACE COLLECTED MATERIAL IN PROPER CONTAINER. SMALL SPILLS-USE
ABSO RBENT TO PICK UP RESIDUE & DISPOSE OF PROPERLY.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH ALL APPLICABLE REGULATIONS
FEDERAL, STATE AND LOCAL. AVOID DISCHARGE TO NATURAL WATERS.
Handling And Storage Precautions: STORE BELOW 100F. KEEP FROM FREEZING.
Other Precautions: USE ONLY W/ADEQ VENT. DO NOT TAKE INTERNALLY. KEEP OUT OF
REACH OF CHILDREN. AVOID CNTCT W/SKIN & EYES, & BRTHG OF VAPS. KEEP
CNTNRS TIGHTLY CLSD & UPRIGHT WHEN NOT IN USE. AVOID CNDTNS WHICH RESULT
I N FORMATION OF INHALABLE
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONE
Extinguishing Media: DRY CHEMICAL OR FOAM WATER FOG. CARBON DIOXIDE.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). WATER MAY BE USED TO COOL AND PROTECT EXPOSED CONTAINER.
Unusual Fire/Explosion Hazard: CLSD CNTNRS MAY BURST IF EXPOSED TO EXTREME
HEAT/FIRE. MAY DECOMPOSE UNDER FIRE CNDTNS EMITTING IRRITANT AND/OR TOX
GASES. IN CLSD TANKS, H*2O/FOAM (SUPDAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW APPLICABLE
STANDARDS. WHERE RESPIRATORY PROTECTION IS REQUIRED, USE ONLY NIOSH APPROVED
RESPIRATORS IN ACCORDANCE WITH OSHA STANDARD 29 CFR 1910.134.
Ventilation: PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT BULD-UP
OF VAPORS.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N). IMPERVIOUS CLOTHING, APRON.
Work Hygienic Practices: WASH HANDS THOROUGHLY AFTER HANDLING, ESPECIALLY
BEFORE EATING OR SMOKING.
Supplemental Safety and Health: MFR'S TRADE NAME/PART #: WALL & TRIM
ENAMEL. EXPLO HAZ: FOAM MAY CAUSE FROTHING OR ERUPTION.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >212F,>100C
Spec Gravity: 1.39 (FP N)
VOC Grams/Liter: 97
Appearance and Odor: NONE SPECIFIED BY MANUFACUTER
Percent Volatiles by Volume: 64.22
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: ELEVATED TEMPERATURES, CONTACT WITH OXIDIZING
AGENT, CONTACT WITH ALUMINUM OR ZINC, FREEZING, SPARKS, OPEN FLAME.
Materials To Avoid: OXIDIZERS, ACIDS, ALUMINUM, ZINC, MAGNESIUM, SODIUM,
POTASSIUM.
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE, OXYGEN.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: UH6800, WHITE, ULTRA-HIDE INTERIOR LATEX EGGSHELL (SUPDAT)
Cage: FO881
Assigned IND: Y
Company Name: ICI PAINTS/GLIDDEN PAINT CO
Street: 925 EUCLID AVENUE
Zipcode: 44115-5000
Label Required IND: Y
Date Of Label Review: 01/09/1998
Status Code: C
Label Date: 01/09/1998
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE: INHALATION: IRRITATION OF
RESPIRATORY TRACT. PROLONGED INHALATION MAY LEAD TO MUCOUS MEMBRANE
IRRITATION, COUGHING, RESPIRATORY PROBLEMS, BRONCHITIS. SKIN CONTACT:
IRRITATION OF SK IN. EYE CONTACT: IRRITATION OF EYES. INGESTION: MAY CAUSE
NAUSEA, GASTRO-INTESTINAL DISTURBANCE. CHRONIC: NONE SPECIFIED BY
MANUFACTURER.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:821K045 01K
Kit Part:Y
CAGE:83574
CAGE:83574
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL 3-ETHOXYPROPIONATE, PROPANOIC ACID, 3-ETHOXY-, ETHYL
ESTER *96-4*
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: 20%
Ingred Name:SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC, HIGH FLASH
AROMATIC NAPHTHA, C8&10 AROMATIC HYDROCARBON *96-4*
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 15%
Ingred Name:2,4-PENTANEDIONE, ACETYLACETONE
*96-4*
CAS:123-54-6
RTECS #:SA1925000
Fraction by Wt: 10%
Ingred Name:METHYL ETHYL KETONE, 2-BUTANONE *96-4*
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 25%
Other REC Limits:590 MG/CUM
OSHA PEL:200 PPM
ACGIH TLV:590 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TOLUENE (IARC CARC- GROUP 3) *96-4*
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 10%
Other REC Limits:375 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BUTYL ACETATE (N-BUTYL ACETATE) *96-4*
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 20%
Other REC Limits:150 PPM
OSHA PEL:710 MG/CUM
ACGIH TLV:713 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:METHYL ETHYL KETONE-INHALATION: THROAT
IRRITATION, CNS EFFECTS, REVERSIBLE LIVER DAMAGE IS POSSIBLE AT
HIGH DOSES.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:BURNING, TEARING, REDDENING, TRANSIENT CORNEAL
CLOUDING, DRYING, CRACKING, COUGH, CHEST PAINS, IRRITATION,
HEADACHE, DIZZINESS, DROWSINESS, NAUSEA.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER.
DON'T USE SOLVENTS. INHALATION: REMOVE TO FRESH AIR. GIVE CPR IF
NEEDED. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:35F
Extinguishing Media:CO2, DRY CHEMICAL/FOAM.
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. COOL
CONTAINERS W/WATER. FOG NOZZLES ARE PREFERRABLE. WEAR NIOSH/MSHA
APPROVED SCBA & PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:VAPOR MAY ACCUMULATE IN INADEQUATELY
VENTILATED/CONFINED AREAS, FORM EXPLOSIVE MIXTURES W/AIR, TRAVEL
LONG DISTANCES, FLASHBACK/FLAME TO HANDLING SITE. (SUPP)
================== Accidental Release Measures ==================
Spill Release Procedures:PROTECT FROM IGNITION. UNVENTILATED-WEAR
AIR-SUPPLIED RESPIRATOR. COVER W/ABSORBENT MATERIAL & SCOOP INTO
CONTAINER. CLEAN RESIDUE W/SUITABLE SOLVENT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. ISOLATE
FROM HEAT & OTHER IGNITION SOURCES. DON'T STORE >120F. DON'T CUT,
PUNCTURE/WELD ON/NEAR DRUMS.
Other Precautions:EMPTY DRUMS MAY CONTAIN EXPLOSIVE VAPORS. VAPORS ARE
>AIR & MAY COLLECT IN LOW/CONFINED AREAS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN SPRAYING/APPLYING, USE AN ORGANIC VAPOR
CARTRIDGE/AIR-SUPPLIED RESPIRATOR.
Ventilation:GENERAL VENTILATION.
Other Protective Equipment:PROTECTIVE CLOTHING, SAFETY SHOWER, EYE
BATH, WASHING FACILITIES.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
UNUSUAL FIRE CONT'D: CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:175-329F
Vapor Density:>1
Spec Gravity:0.879
Appearance and Odor:LIQUID W/SOLVENT ODOR.
Percent Volatiles by Volume:80
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, ELECTRICAL EQUIPMENT, SPARKS, FLAME
& OTHER IGNITION SOURCES.
Hazardous Decomposition Products:COMBUSTION: CO2, CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:WHEN DISPOSING, ENSURE THAT IT'S PACKAGED,
STORED, TRANSPORTED & MANAGED IAW/FEDERAL, STATE & LOCAL
REGULATIONS. FLAMMABLE LIQUID, UN1263.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:0390, 0391, 8719, 8720, 8727 THREE-IN-ONE (SUP DAT)
Preparer's Name:GENE F TAPPAN
CAGE:NO007
CAGE:90994
CAGE:NO007
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HEAVY NAPHTHENIC;
(DISTILLATES, HEAVY NAPHTHENIC)
CAS:64741-53-3
RTECS #:PY8034000
Fraction by Wt: >97%
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL OR FATAL IF SWALLOWED.
CONTAINS PETROLEUM DISTILLATES. SKIN/EYES/INHAL: TOXICOLOGY STUDIES
HAVE SHOWN THE MATERIAL TO BE OF VERY LOW ACUTE TOXICITY AND
NON-IRRITANT. THERE IS NO SPECIFIC ANTID OTE. TREATMENT OF
OVEREXPOSURE SHOULD BE DIRECTED AT THE CONTROL OF SYMPTOMS AND THE
CLINICAL CONDITION.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST: DO NOT INDUCE VOMITING. CALL MD IMMEDIATELY. EYES:
FLUSH W/POTABLE WATER FOR AT LEAST 15 MIN. SEE MD . SKIN: FLUSH
W/COPIOUS AMOUNTS OF WATER. SEE MD . INHAL: REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE OXYGEN, ARTIFICIAL RESPIRATION) .
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:>305F,>152C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, WATER SPRAY, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . WATER SPRAY OR FOAM MAY CAUSE FROTHING.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP WITH ABSORBENT MATERIAL. WASH AREA
WELL WITH SOAPY WATER TO AVOID SLIPPERY CONDITION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN
Other Precautions:THE PRECAUTIONARY MEASURES PROVIDED HEREIN PERTAIN TO
CONSUMER USE OF THIS PRODUCT. FOR WORKPLACE EXPOSURE SIGNIFICANTLY
GREATER THAN NORMAL CONSUMER USE, APPLY APPROPRIATE INDUSTRIAL
HYGIENE PRINCIPL ES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
TRADE NAME/PART NO: HOUSEHOLD OIL.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>550F,>288C
Spec Gravity:0.886-0.923
Evaporation Rate & Reference:NIL
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR AMBER LIQUID WITH FAINT CITRONELLA-LIKE ODOR
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:CO, CO*2, NO*2, SO*2, ALDEHYDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:LARGE QUANTITY DISPOSAL: DISPOSE OF IN
ACCORDANCE W/LOCAL, STATE & FEDERAL LAW GOVERNING. CONSUMER
DISPOSAL: DISPOSAL OF OILY WASTES. DISCARD SINGLE CONTAINER IN
TRASH COLLECTION.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:MIL-L-46152;15W40;ENGINE LUBE OIL
Preparer's Name:THOMAS G. MUSILLI
CAGE:61808
CAGE:61808
CAGE:60226
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL
CAS:64742-65-0
RTECS #:PY8038500
Fraction by Wt: 75.7%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3
Ingred Name:LUBRIZOL 4856A (LUBRIZOL, CLEVELAND, OH)
Fraction by Wt: 12.2%
Other REC Limits:NONE SPECIFIED
Ingred Name:OLIFIN COPOLYMER ( EXXON CO. HOUSTON,TX)
Fraction by Wt: 12.0%
Other REC Limits:NONE SPECIFIED
Ingred Name:ACRYLIC COPOLYMER (ROHM & HAAS CO. PHILADELPHIA,PA)
Fraction by Wt: 0.1%
Other REC Limits:NONE SPECIFIED
Ingred Name:MFR ALSO LISTS "ZINC COMPOUNDS" SUBJECT TO COMMUNITY RIGHT
TO KNOW IN ANOTHER LOCATION. THIS MAKS % GRATER THAN 100.
RTECS #:9999999ZZ
Fraction by Wt: 2.4%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG ZNO/M3
ACGIH TLV:5 MG ZNO/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT IS VERY MILDLY IRRITATING TO
BODY TISSUES. MOST LIKELY HAZARD IS THAT OF BREATHING THE MIST OR
VAPORS SHOULD THE PRODUCT BE HEATED OR MISTED.
Explanation of Carcinogenicity:THE PRODUCT CONTAINS NO INGREDIENT THAT
IS LISTED BY IARC, NTP OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYE:MILD IRRITATION. SKIN:POSSIBLE MILD
IRRITATION. INHALED:RESPIRATORY IRRITATION,POSSIBLE PULMONARY EDEMA
IF MIST IS INHALED. INGESTED:NONE GIVEN BY MANUFACTURER
(SUPPLIER).
Medical Cond Aggravated by Exposure:NONE REPORTED
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WATER 15 MIN, HOLD LIDS OPEN. SKIN:WASH WITH
SOAP & WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE
REUSE. INHALED:REMOVE TO FRESH AIR. RESTORE BREATHING IF
NECESSARY.INGESTED:D O NOT INDUCE VOMITING. GIVE 2 LARGE GLASSES
OF MILK OR WATER AND GET IMMEDIATE MEDICAL CARE. GIVE NOTHING BY
MOUTH IF UNCONSCIOUS. IF IRRITATION PERSISTS OR IS SEVERE,SEE A
DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:440F,227C
Autoignition Temp:Autoignition Temp Text:470F
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:NONE GIVEN BY MANUFACTURER (SUPPLIER).
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER AS LIQUID IF POSSIBLE. ADSORB
REMAINDER ON EARTH,SAND,SAWDUST,ETC. KEEP OUT OF DRAINS, SEWERS,
AND WATERWAYS. STORE IN CLOSED CONTAINERS PENDING DISPOSAL.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR WILL NOT NORMALLY BE NECESSARY. USE
NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR OR RESPIRATOR FOR OIL
MIST IF EXPOSURE IS ABOVE THE TLV/PEL. SEE 29 CFR 1910.134 FOR
REGULATIONS PERTAINING TO RESPIRATOR USE.
Ventilation:NORMAL ROOM VENTILATION SHOULD BE SUFFICIENT. SUPPLEMENT
WITH LOCAL EXHAUST IF NEEDED (OIL MIST).
Other Protective Equipment:AS NEEDED TO PREVENT PROLONGED/REPEATED
CONTACT.
Work Hygienic Practices:USE GOOD INDUSTRIAL HYGIENE PRACTICE. MINIMIZE
PERSONAL CONTACT. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
MFR CODE 60,501-15/40
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:700F,371C
Spec Gravity:0.89
Solubility in Water:NEGLIGIBLE
Appearance and Odor:FLUID OIL, BLAND ODOR
Percent Volatiles by Volume:UNKNON
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:CARBON DIOXIDE,CARBON MONOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W FEDERAL,STATE, LOCAL REGULATIONS.
MFR SUGGESTS RECYCLE OR IF THAT IS NOT PRACTICLE TO INCINERATE.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:LC-800 SERIES OPC CARTRIDGE
CAGE:62803
CAGE:62803
============= Composition/Information on Ingredients =============
Ingred Name:PIGMENT; (PHTHALOCYANINE PIGMENT)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLYCARBONATE; (POLYCARBONATE VEHICLE)
Fraction by Wt: 60%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:HYDRAZONE COMPOUND ADDITIVE
Fraction by Wt: 40%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE AND CHRONIC: NONE ESTABLISHED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:NONE REQUIRED. INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO
FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP) .
EYES:IMMEDIATELY FLUSH W/POTABLE WATER FOR A MINIMUM OF 15 MINUTES,
SEEK ASS ISTANCE FROM MD . SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER.
CALL MD .
===================== Fire Fighting Measures =====================
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM, WATER.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:NO SPECIAL PRECAUTIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DARK, DRY PLACE.
Other Precautions:DO NOT EXPOSE TO LIGHT. DO NOT TOUCH THE SURFACE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED. NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NOT APPLICABLE.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NOT APPLICABLE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:2.7 (H*2O = 1)
Solubility in Water:INSOLUBLE
Appearance and Odor:GREEN, ODORLESS, SOLID CYLINDER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:MAY BE DISPOSED OR INCINERATED UNDER CONDITIONS
WHICH MEET ALL FEDERAL, STATE OR LOCAL ENVIRONMENTAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:INSULCAST 165 LV PART A, IC-O165-088700-A
Kit Part:Y
Preparer's Name:LAWRENCE T. DEMAIO
CAGE:13549
CAGE:13549
============= Composition/Information on Ingredients =============
Ingred Name:MODIFIED EPOXY RESIN (VAPOR PRESSURE 20.0MM HG @ 20C) MAY
CONTAIN EPICHOROHYDRIN,106-89-8, 2-3 PPM, (SARA 313)
Fraction by Wt: 28-34%
Other REC Limits:NONE SPECIFIED
ACGIH TLV:2PPM/ 20 MG/M3
Ingred Name:EPOXY RESIN (VAPOR PRESSURE .01 MM HG @ 20C)
Fraction by Wt: 3-5%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:IRRITATION TO RESPIRATORY TRACT, EYES
AND SKIN. SKIN SENSITIZATION AND ALLERGIC RESPONSE.
Medical Cond Aggravated by Exposure:DERMITITIS
======================= First Aid Measures =======================
First Aid:MOVE TO FRESH AIR. CPR IF NECESSARY. WASH SKIN WITH SOAP AND
WATER/WATERLESS HAND CLEANER. REMOVE CONTAMINATED CLOTHING. DO NOT
INDUCE VOMITING. DRINK LARGE QUANTITIES OF WATER/MILK MIXED WITH
SALT NE VER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. FLUSH
EYES WITH WATER FOR 15 MIN.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:207F,97C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL, SAND.
Fire Fighting Procedures:USE SCBA & PROTECT CLOTHING. WATER FOG TO COOL
CONTAINERS. CLOSE ALL VALVES TO AREA. USE EMERG LIGHTS. SHUT OF
POWER TO AREA. BE SAFE DISTANCE AWAY.
Unusual Fire/Explosion Hazard:IRRITATING AND/OR TOXIC GASES MAY BE
PRESENT.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE/ABSORB WITH SAND AND DISPOSE IN APPROVED
MANNER. REMOVE ALL IGNITE SOURCES. WEAR PROTECTIVE CLOTHES. STOP
FROM ENTERING UNDERGROUND WATER SYSTEM. FLUSH AREA, BUT NOT TO
SEWER. VENTILATE AREA. TRA NSPORT SPILL CALL: 800-424-9300.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL DRY PLACE. KEEP AWAY
FROM OPEN FLAMES. KEEP CONTAINER CLOSED WHEN NOT IN USE. STORE AWAY
FROM FOOD.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NESA/NIOSH APPROVED RESPIRATOR IS HIGHLY
RECOMMENDED. SCBA IN CONCENTRATIONS ABOVE PEL/TLV. AVOID BREATHING
FUMES, MISTS AND VAPORS.
Ventilation:PROVIDE ADEQUATE CROSS AIR CIRCULATION.
Other Protective Equipment:EYEWASH STATION/EMERGENCY SHOWER/BARRIER
CREAM. CHEMICAL APRON RUBBER FOOT COVERING, CLEAN LONG SLEEVE AND
LEG CLOTHING.
Work Hygienic Practices:WASH AFTER HANDLING. WASH BEFORE EATING,
DRINKING, SMOKING, OR USING TOILET.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:1.81
Evaporation Rate & Reference:< THAN N-BUTYL ACETATE
Solubility in Water:NEGLIGIBLE (<0.1%)
Appearance and Odor:SILVER PASTE, SLIGHT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ACIDS AND BASES AND/OR CONCENTRATED ALKALI.
Hazardous Decomposition Products:OXIDES OF CARBON AND ALDEHYDES. TOXIC
MONOMER FUMES AND/OR SHORT CHAIN HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN APPROVED MANNER. DISPOSE OF IN
ACCORDANCE WITH LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:146 3272 POTASSIUM BROMIDE (ANHYDROUS)
Preparer's Name:UNKNOWN.
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM BROMIDE
CAS:7758-02-3
RTECS #:TS7650000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS 3200-6400 MG/KG.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES. ACUTE- EYES:NO
SPECIFIC HAZARD KNOWN. MAY CAUSE TRANSIENT IRRITATION. SKIN:LOW
HAZARD FOR RECOMMENDED HANDLING. INHALE:EXPECTED TO BE A LOW HAZARD
FOR RECOMMENDED HANDLING. ORAL:EX PECTED TO BE A LOW INGESTION
HAZARD. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING EYE
PROBLEMS MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. EYES:FLUSH WITH WATER FOR 15 MINUTES, HOLDING EYELIDS OPEN.
SKIN:WASH WITH SOAP & WATER. ORAL:DRINK 1-2 GLASSES OF WATER. SEEK
MEDICA L ATTENTION. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NOT RELEVANT
Upper Limits:NOT RELEVANT
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. HAZARDOUS DECOMPOSITION
PRODUCTS MAY BE FORMED.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNT OF WATER IF
PERMITTED OR SWEEP UP AND PLACE IN A CONTAINER FOR CHEMICAL WASTE.
CLEAN SURFACE THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION. AVOID
RAISING DUST.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. MINIMIZE DUST
GENERATION AND ACCUMULATION.
Other Precautions:AVOID CONTACT WITH EYES. USE WITH ADEQUATE
VENTILATION. WASH THOROUGHLY AFTER HANDLING. KEEP OUT OF REACH OF
CHILDREN. DO NOT BREATHE DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES/HR)
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:EYE BATH, WASHING FACILITIES, SAFETY SHOWER
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
ECOLOGICAL INFORMATION: THIS MATERIAL IS EXPECTED TO HAVE THE FOLLOWING
PROPERTIES: NO BIOCHEMICAL OXYGEN DEMAND, A LOW POTENTIAL TO AFFECT
AQUATIC ORGANISMS. WHEN DILUTED WITH A LARGE AMOUNT OF WATER , THIS
MATERIAL RELEASED DIRECTLY OR INDIRECTLY INTO THE ENVIRONMENT IS
NOT EXPECTED TO HAVE A SIGNIFICANT IMPACT.
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NOT RELEVANT
Melt/Freeze Pt:M.P/F.P Text:1346F,730C
Spec Gravity:2.75
Viscosity:NOT RELEVANT
Evaporation Rate & Reference:NOT RELEVANT
Solubility in Water:APPRECIABLE
Appearance and Odor:WHITE POWDER - ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE WITH COMMON MATERIALS AND CONTAMINANTS WITH WHICH THE MATERIAL MAY
REASONABLY COME INTO CONTACT.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:HYDROGEN BROMIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE OR LOCAL REGULATIONS. FLUSH TO SEWER WITH LARGE
AMOUNT OF WATER, IF ALLOWED.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:TOTAL LOOK, TIRE AND VINYL DRESSING
Preparer's Name:GARY M GRECO
CAGE:66400
CAGE:66400
============= Composition/Information on Ingredients =============
Ingred Name:C11-13 ISOPARAFFIN
CAS:64742-48-9
Fraction by Wt: 60-70%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: DRYING, IRRITATION, DEFATTING,
DERMATITIS. EYE: IRRITATION. INGEST: HARMFUL/FATAL.
Medical Cond Aggravated by Exposure:DRYING EFFECTS
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/WATER FOR 15 MINUTES. GET MED AID. SKIN: FLUSH
W/WATER FOR 15 MINUTES. GET MED AID. INHAL: REMOVE TO FRESH AIR.
INGEST: GET IMMEDIATELY MED AID.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:144F,49C
Lower Limits:1.0
Upper Limits:7.0
Extinguishing Media:CO, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE SCBA.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT MATERIAL TO SOAK UP SPILLS.
CAUTION: AREA WILL BE SLIPPERY.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM IGNITION SOURCES. KEEP
CONTAINER TIGHTLY CLOSED. KEEP OUT OF REACH OF CHILDREN
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NA
Ventilation:ADEQUATE
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:ABOUT 350F
Vapor Pres: 0.5
Vapor Density:>1.0
Spec Gravity:0.810
pH:NA
Evaporation Rate & Reference:>1.0 (WATER)
Solubility in Water:INSOLUBLE
Appearance and Odor:BLUE LIQUID W/WATERMELON ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:NOT DETERMINED.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE W/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:NP SERIES
CAGE:77280
CAGE:77280
============= Composition/Information on Ingredients =============
Ingred Name:DILUTED SULFURIC ACID (SARA III)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 32-40%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: YES. CHRONIC: NO.
Effects of Overexposure:CONTACT TO SENSITIVE SKIN OR PROLONGED CONTACT
WITH NORMAL SKIN MAY CAUSE MILD IRRITATION.
Medical Cond Aggravated by Exposure:IRRITATION, BURNS, ULCERATION.
======================= First Aid Measures =======================
First Aid:SKIN-FLUSH AFFECTED AREA WITH LARGE AMOUNTS OF COOL CLEAN
WATER. IF REDNESS OR BLISTERING OCCURS, CONSULT PHYSICIAN.
EYE-CORNEA COULD BE DAMAGED. FLUSH WITH LARGE AMOUNTS OF COOL WATER
FOR AT LEAST 15 MIN. CONSULT PHYSICIAN. INGEST-DRINK LARGE AMOUNTS
OF WATER & CONSULT PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NONCOMBUSTIBLE
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, WATER FOG, WATER.
Fire Fighting Procedures:SULFURIC ACID FUME, SULFUR DIOXIDE GAS OR
CARBON MONOXIDE MAY BE RELEASED WHEN ACID DECOMPOSES; WEAR
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:REACTS WITH METALS TO YIELD EXPLOSIVE/
FLAMMABLE HYDROGEN GAS; THIS REACTION IS INTENSIFIED WHEN ACID IS
DILUTED, AS IN ELECTROLYTE.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN AREA WITH PLAIN WATER. WASH HANDS AND
OTHER SKIN AREAS WITH COOL WATER AND MILD SOAP. DO NOT TOUCH EYES!
======================Handling and Storage ======================
Handling and Storage Precautions:WEAR APPROPIATE PROTECTIVE CLOTHING.
Other Precautions:AVOID PROLONGED CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER NORMAL CONDITIONS.
Other Protective Equipment:LONG SLEEVED SHIRTS, LONG PANTS, CLOSED
SHOES.
Work Hygienic Practices:WASH HANDS OR OTHER AREAS THOROUGHLY AFTER
CONTACT.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:203F,95C
Melt/Freeze Pt:M.P/F.P Text:-94F,-70C
Vapor Pres:10
Vapor Density:>1
Spec Gravity:1.245 TO 1.295
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
COMBUSTIBLES, ORGANIC MATERIALS, STRONG REDUCING AGENTS, METALS, SULFUR
DIOXIDE FUMES.
Stability Condition to Avoid:BREAKING OR CRUSHING OF BATTERY CASE.
Hazardous Decomposition Products:DECOMPOSITION OF SULFURIC ACID
RELEASES SULFUR TRIOXIDE, CARBON MONOXIDE, SULFURIC ACID FUME,
SULFUR DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE WITH OTHER SOLID WASTE. DO NOT
INCINERATE!
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:896 2250 RP FIXER AND REPLENISHER XF1, WORKING SOLUTION
CAGE:5K871
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 85-90%
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMMONIUM THIOSULFATE
CAS:7783-18-8
RTECS #:XN6465000
Fraction by Wt: 10-15%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ALUMINUM SULFATE
CAS:10043-01-3
RTECS #:BD1700000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:AMMONIUM BISULFITE (CERCLA)
CAS:10192-30-0
RTECS #:WT3595000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SODIUM BISULFITE (SASA III) (CERCLA)
CAS:7631-90-5
RTECS #:VZ2000000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:EXPECTED TO BE A LOW HAZARD FOR
RECOMMENDED HANDLING. EYES:NO SPECIFIC HAZARD KNOWN.MAY CAUSE
TRANSIENT IRRITATION. SKIN:LOW HAZARD FOR RECOMMENDED HNDLG.
INGEST:EXPECTED TO BE LOW INGESTION HAZ ARD.
Explanation of Carcinogenicity:PER MSDS:CARCINOGENICITY
CLASSIFICATION:IARC/ACGIH/NTP/OSHA:NONE.
Effects of Overexposure:TRANSIENT EYE IRRIT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:IF SYMPTOMATIC MOVE TO FRESH AIR. GET MED ATTN IF
SYMPTONS PERSIST. EYES:ANY MATL THAT CONTACTS EYE SHOULD BE WASHED
OUT IMMED W/WATER. SYMPTOMS OCCUR GET MED ATTN. SKIN:WASH W/SOAP &
WATER. GETMED ATTN IF SYMPTOMS OCCUR. INGEST:DRINK 1-2 GLASSES OF
WATER. SEEK MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:NONE,NON-COMBUST
Autoignition Temp:Autoignition Temp Text:NP
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER W/LG AMTS OF WATER.OTHERWISE
ABSORB W/VERMICULITE OR OTHER INERT MATERIAL, THEN PLACE IN
CONTAINER FOR CHEMICAL WASTE. CLEAN SURFACE THOROUGHLY TO REMOVE
RESIDUAL CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE W/ADEQUATE VENTILATION.KEEP FROM
CONTACT W/OXIDIZING MATLS.KEEP CNTNR TIGHTLY CLSD.KEEP AWAY FROM
INCOMPA SUBSTANCES.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES/HR)
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:EYEBATH, WASHING FACILITIES, SAFETY SHOWER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HNDLG.GOOD INDUSTRIAL HYG
PRAC TO MIN EYE/SKIN CONTACT.
Supplemental Safety and Health
PH:4.2-4.5.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:NP
Decomp Temp:Decomp Text:NP
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.069
pH:SUPPLE
Viscosity:NP
Evaporation Rate & Reference:NP
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID, COLORLESS, ODORLESS
Percent Volatiles by Volume:85-90
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BASES, SODIUM HYPOCHLORITE (BLEACH), STRONG OXIDIZING AGENTS, STRONG
ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NITROGEN OXIDES (NOX), SULFUR DIOXIDE,
AMMONIA, CHLORAMINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE/TREATMENT/DISPOSAL MAY BE SUBJECT TO
NATIONAL/STATE/LOCAL LAWS. FLUSH TO SEWER W/LG AMTS OF WATER. CHEM
SUBJ TO REPORTING REQMTS OF SEC 313 TITLE III SARA/40CFR372:NONE.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SYLOID SILICAS ID/AEROGEL GRADES, 72
Preparer's Name:J.H. CONVEY
CAGE:16210
CAGE:16210
============= Composition/Information on Ingredients =============
Ingred Name:SILICA GEL; (SYNTHETIC AMORPHOUS SILICA)
CAS:63231-67-4
RTECS #:VV7322000
Fraction by Wt: 99.4%
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT)EST. >31,600 MG/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SILICA GEL IS A SYNTHETIC AMORPHOUS
SILICA NOT TO BE CONFUSED W/CRYSTALLINE SILICA. EPIDEMIOLOGICAL
STUDIES INDICATE LOW POTENTIAL FOR ADVERSE HEALTH EFFECTS. SILICA
GEL IS CONSIDERED BY DAVISON TO BEA NUISANCE DUST. IN ACTIVATED
FORM, SILICA GEL ACTS AS A DESICCANT & CAN CAUSE A DRYING
IRRITATION OF (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:MUCOUS MEMBRANES & SKIN IN CASES OF
SEVERE EXPOSURE. NOT CONSIDERED AN OCULAR IRRITANT. ANIMAL TESTS
WITH AN 18 MONTH EXPOSURE AT 15 MG/M3 SHOWED SILICA DEPOSITION IN
RESPIRATORY MACROPHAGES AND LYMPH NODES, MINIMUM LUNG FUNCTION
IMPAIRMENT, AND NO SILICOSIS.
Medical Cond Aggravated by Exposure:NO MEDICAL CONDITIONS ABNORMALLY
AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYE:IMMEDIATELY WASH W/LARGE AMOUNTS OF WATER FOR AT LEAST 15
MIN, OCCASIONALLY LIFTING LIDS. IF IRRITATION OCCURS & PERSISTS,
GET MD. SKIN:WASH W/SOAP & WATER. INGEST:MATERIAL WILL PASS THROUGH
THE B ODY NORMALLY. INHAL:REMOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Extinguishing Media:NON-FLAMMABLE. USE MEDIA SUITABLE FOR SURROUNDING
FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:NOT KNOWN TO HAVE ANY ADVERSE EFFECT ON THE
AQUATIC ENVIRONMENT. THEY ARE INSOLUBLE AND NON-TOXIC. SWEEP OR
VACUUM UP OR FLUSH TO SEWER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:WHEN POURING INTO A CNTNR OF FLAMMABLE
LIQUID, GROUND BOTH CNTNRS ELECTRICALLY TO PREVENT STATIC ELECTRIC
SPARK. KEEP TIGHTLY SEALED TO PROT QUALITY.
Other Precautions:AVOID PRLNGD BRTHG OF DUST/CNTCT OF DUST W/SKIN.
DRYING ACTION CAN CAUSE IRRIT OF MUCOUS MEMBRANES OF NOSE & THROAT
& IRRIT OF SKIN. IF USE REQUIRES (SUPP DATA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF DUSTY CONDITIONS PREVAIL, WEAR PROPERLY
FITTED NIOSH/MSHA APPROVED DUST RESPIRATOR.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:LONG SLEEVES.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PH: 5% SLURRY: 6-8. OTHER PREC: MANUAL HNDLG, WEAR LONG SLEEVES &
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:2.1
pH:SUPDAT
Solubility in Water:INSOLUBLE
Appearance and Odor:DRY WHITE POWDER, AVERAGE PARTICLE SIZE 2.5-15
MICRONS, NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTS WITH HYDROGEN FLUORIDE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN AN APPROVED LANDFILL ACCORDING TO
FEDERAL, STATE AND LOCAL REGULATIONS. COVER PROMPTLY TO AVOID
BLOWING OF DUST.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:154 1069 EKTACOLOR PRIME STAB+REPL/EP-2NP,RA-4NP WORK SOLN
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 95-100%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYVINYL PYRROLIDONE
CAS:9003-39-8
RTECS #:TR8160000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ORGANO SILICONE
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SUBSTITUTED THIAZOLIN-3-ONE
Fraction by Wt: <0.1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:MAY CAUSE IRRITATION.SKIN:MAY
CAUSE IRRITATION.INHAL:EXPECTED TO BE A LOW HAZARD FOR NORMAL
SERVICE.INGEST:EXPECTED TO BE A LOW HAZARD FOR NORMAL SERVICE.
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of Overexposure:SKIN:ALLERGIC SKIN REACTIONS.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
CONDITIONS MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH SOAP AND
WATER.EYES:FLUSH WITH WATER FOR 15 MINUTES.INHAL:REMOVE TO FRESH
AIR.GIVE OXYGEN OR ARTIFICIAL RESPIRATION IF NEEDED.INGEST:DO NOT
INDUCE VOMITING. GET PROMPT QUALIFIED MEDICAL ATTENTION.IF
CONSCIOUS,DRINK 1-2 GLASSES OF WATER.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP WITH NON-COMBUSTIBLE INERT
ADSORBANT(EG.CLAY);PLACE COLLECTED MATERIEL IN AN APPROPRIATE
CONTAINER FOR DISPOSAL;CLEAN SPILL AREA TO REMOVE
SLIPPERINESS.SMALL SPILLS CAN BE FLUSHED TO SEWER WIT H PLENTY OF
WATER.CLEAN SPILL AREA IF SLIPPERY.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED.EMPTY
CONTAINER MAY BE DANGEROUS;DISPOSE OF PROPERLY.
Other Precautions:AVOID BREATHING VAPORS OR MISTS. DO NOT GET IN EYES,
ON SKIN OR ON CLOTHING. WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING OR DRINKING. REMOVE CONTAMINATED CLOTHING PROMPTLY. KEEP OUT
OF REACH OF C HILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NESCESSARY IN NORMAL SERVICE.
Ventilation:USE GENERAL DILUTION VENTILATION.MFR RECOMMENDS 10 AIR
CHANGES PER HOUR.
Other Protective Equipment:PROTECTIVE CLOTHING,AS NEEDED.PROVIDE A
LOCAL EYE WASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS.SEPERATE WORK CLOTHES FROM STREET
CLOTHES.LAUNDER WORK CLOTHES BEFORE REUSE.KEEP FOOD OUT OF THE WORK
AREA.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:T6
NRC/State Lic Num:NOT RELEVENT
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:18 @ 68F
Vapor Density:0.4
Spec Gravity:1.015
pH:7 - 9
Solubility in Water:COMPLETE
Appearance and Odor:BROWN LIQUID - ODORLESS
Percent Volatiles by Volume:95-100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE WITH COMMON MATERIALS AND CONTAMINANTS WITH WHICH THE MATERIAL MAY
REASONABLY COME INTO CONTACT.
Stability Condition to Avoid:EXTREME HEAT
Hazardous Decomposition Products:NON-COMBUSTIBLE ITEM.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS & STEEL OVERALL COMPOSITION
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:RTC EPOXY PART A
CAGE:19739
CAGE:19739
============= Composition/Information on Ingredients =============
Ingred Name:DIGLYCIDYL ETHER OF BISPHENOL A
CAS:1675-54-3
RTECS #:TX3800000
===================== Hazards Identification =====================
Effects of Overexposure:EYE & SKIN: RPTD/PRLNG CONTACT MAY CAUSE IRRIT
& OTHER ALLERGIC RESPONSES SUCH AS DERMATITIS.
======================= First Aid Measures =======================
First Aid:SKIN: WASH IMMED WITH SOAP AND WATER. EYE: FLUSH WITH PLENTY
OF WATER FOR 15 MIN, CALL MD. REMOVE AND WASH CONTAMINATED CLOTHING
BEFORE REUSE.
===================== Fire Fighting Measures =====================
Flash Point:470F;243C, COC
Extinguishing Media:CO*2, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE
Unusual Fire/Explosion Hazard:AVOID EXTREME HEAT, OPEN FLAME, ELECTRIC
SPARKS.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP IN ABSORBENT, & FLUSH WITH PLENTY OF
WATER.
======================Handling and Storage ======================
Other Precautions:MAY CAUSE SKIN IRRITATION,AVOID CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED AIR MASK IF IN CONFINED
AREA. (MFR)
Ventilation:LOCAL: PREFERABLE. MECH: ACCEPTABLE.
Other Protective Equipment:SAFETY SHOWER & EYE BATH. USE COVERALLS &
APRON.
Supplemental Safety and Health
V.P. VALUE IS 0.01. PART A OF A 2 PART KIT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:500F;260C
Spec Gravity:1.16
Evaporation Rate & Reference:>1, (BU AC=1)
Appearance and Odor:LIGHT COLOR, MEDIUM VISCOSITY LIQUID.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS,AMINES, MERCAPTANS AND BASES.
Conditions to Avoid Polymerization:STRONG ACIDS,AMINES,MERCAPTANS &
BASES.
==================== Disposal Considerations ====================
Waste Disposal Methods:MFR RECOMMENDS BURYING OR INCINERATION DISPOSAL
METHOD MUST BE IAW FEDERAL,STATE & LOCAL CODES.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:93-005
CAGE:0BA38
CAGE:0BA38
CO.
CAGE:9V583
============= Composition/Information on Ingredients =============
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Other REC Limits:NONE SPECIFIED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192
Ingred Name:NAPHTHENIC ACID; LEAD SALT
CAS:61790-14-5
RTECS #:QK9150000
Fraction by Wt: 2%
Other REC Limits:NONE SPECIFIED
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:NAPHTHA, LIGHT ALIPHATIC (PETROLEUM) (THIS MATERIAL
CONTAINS UP TO 5 VOL.% BENZENE AND 20 VOL.% N-HEXANE)
CAS:64742-89-8
Other REC Limits:NONE SPECIFIED
Ingred Name:NAPHTHA, MEDIUM ALIPHATIC
CAS:64742-88-7
Other REC Limits:NONE SPECIFIED
Ingred Name:TRADE SECRET
Other REC Limits:NONE SPECIFIED
OSHA PEL:NONE
ACGIH TLV:NONE
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:INGESTION; GASTROINTESTIONAL DISTRESS,
CALL A PHYSCIAN. INHALATION; NOSE AND THROAT IRRITATION,NERVOUIS
SYSTEM DISORDER CHARACTERIZED BY HEADACHE,DIZZINESS
NAUSEA,STAGGERING GAIT,CONFUSION THEN UNCONS
CIOUNESS.SKIN/EYE;IRRITATION OR BURNINGOF EYES.DISCOMFORT OR
DERMITITIS.
Effects of Overexposure:INTENTIONAL MISUSE BY DELIBERATING
CONCENTRATING AND INHALING THE MATERIAL MAY BE HARMFUL OR
FATAL.WITH PERMANET BREAIN AND NERVOUS SYSTEM DAMAGE.
Medical Cond Aggravated by Exposure:NOT GIVEN
======================= First Aid Measures =======================
First Aid:IGESTION;CALL A PHYSCIAN. INHALATION;REMOVE TO FRESH AIR,IF
NOT BREATHING, GIVE ARTIFICAL RESPIRATION,IF BREATHING DIFFICULTY
PRESISIT OR OCCURS LATER CALL A PHYSCIAN. SKIN/EYES;FLUSH EYES WITH
FOR 15 MINUTES WITH PLENTY OF WATEER CALL A PHYSCIAN,WASH SKIN
WIYH SOAP AND WATER,IF IRRITATION PERSIST CALL A PHYSCIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>20F,>-7C
Lower Limits:1.0
Upper Limits:7.01
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:FULL PROTECTIVE CLOTHING, INCLUDING SCBA IS
RECOMMENDED. WATER FROM FOG NOZZLES MAY BE USED TO COOL CLOSED
CONTAINERS TO PREVENT PRESSURE BUILD UP.
Unusual Fire/Explosion Hazard:CONTENTS UNDER PRESSURE, KEEP AT ROOM
TEMPERATURE, FINE MISTA OR SPRAYS MAY BE FLAMMABLE AT TEMPERATURES
BELOW THE FLASH POINT.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA,REMOVE SOURCES OF IGNITION,
PREVENT SKIN CONTACT AND BREATHING OF VAPORS, CONFINE AND REMOVE
WITH INERT ABSORBENT MATERIAL.
Neutralizing Agent:NA
======================Handling and Storage ======================
Handling and Storage Precautions:OBSERVE LABEL PRECAUTIONS.KEEP AWAY
FROM HEAT, SPARKS OR FLAME.DO NOT STORE ABOVE 120F.
Other Precautions:DO NOT SAND, FLAME CUT,BRAZE OR WELD DRY
COATINGWITHOUT APPROVED NIOSH/MSHA RESPIRATOR.DO NOT PUNCTURE CANS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DO NOT BREATH VAPORS OR MISTS. WEAR AN
APPROPIATE PROPERLY FITTED VAPOR/PARTICLE NIOSH/MSHA APPROVE
RESPIRATOR.
Ventilation:PROVIDE SUFFICENT VENTILATION TO KEEP TLV BELOW ALLOWABLE
LIMITS.
Other Protective Equipment:NEIPRENE APRON
Work Hygienic Practices:WASH HANDS AFTER USINGS
Supplemental Safety and Health
PROTECTIVE CREAMS MAY BE USED FOR CLEAN -UP NOT PROTECTION.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:>20F,>-7C
Vapor Pres:NOT GIVEN
Vapor Density:> AIR
Spec Gravity:NOT LISTED
Evaporation Rate & Reference:< ETHER
Solubility in Water:NIL
Appearance and Odor:BLACK LIQUID, PAINT ODOR
Percent Volatiles by Volume:54.2
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:DO NOT STORE ABOVE 120F
Hazardous Decomposition Products:CO,CO2,SMOKE, OXIDES OF HEAVY METALS./
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND.
INCINERATE ABSORBED MATERIALS IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REQUIREMENT. DO NOT INCINERATE IN CLOSED CONTAINERS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:44 L-TEC SOLID STEEL WELDING ELECTRODES
CAGE:EO381
CAGE:55019
CAGE:EO381
============= Composition/Information on Ingredients =============
Ingred Name:CARBON (GRAPHITE, SYNTHETIC)
CAS:7440-44-0
RTECS #:FF5250100
Fraction by Wt: 0.10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9394
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 2.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9394
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: 0.10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9394
Ingred Name:COPPER (SARA III)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: <0.5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2 MG/M3 FUME; 9394
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:MOLYBDENUM (INSOLUBLE COMPOUNDS)
CAS:7439-98-7
RTECS #:QA4680000
Fraction by Wt: 0.5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9394
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 0.65%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9394
Ingred Name:IRON
CAS:7439-86-6
RTECS #:NO6925000
Fraction by Wt: BALANCE
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EXPOSURE TO FUMES MAY CAUSE EYE
& RESPIRATORY TRACT IRRITATION. SOME GASES INHALED MAY CAUSE
PULMONARY EDEMA, ASPHYXIATION & DEATH. CHRONIC: PROLONGED OR
REPEATED EXPOSURE MAY CAUSE IMPAIRED LU NG FUNCTION, CNS EFFECTS
(MN), LUNG CANCER (CR).
Explanation of Carcinogenicity:NICKEL IS LISTED AS A CARCINOGEN BY NTP
& IARC.
Effects of Overexposure:INHALATION: NAUSEA, DIZZINESS,DRYNESS OF NOSE
AND THROAT, COUGHING, WHEEZING, CHEST PAIN, HEADACHE AND SHORTNESS
OF BREATH. EYES: REDNESS, TEARING, BLURRED VISION.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH ALLERGIES OR
IMPAIRED RESPIRATORY FUNCTION MAY HAVE SYMPTOMS WORSENED BY
EXPOSURE TO WELDING FUMES.
======================= First Aid Measures =======================
First Aid:IN CASE OF EMERGENCY CALL FOR MEDICAL AID. EMPLOY FIRST AID
TECHNIQUE RECOMMENDED BY AMERICAN RED CROSS. IF BREATHING IS
DIFFICULT, GIVE OXYGEN AND CALL DOCTOR. FOR ELECTRICAL SHOCK
DISCONNECT AND TUR N OFF THIS POWER. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRATION; IF NO PULSE, ADMINISTER CPR. IMMEDIATLY
CALL FOR MEDICAL AID. FOR ARC BURN, APPLY COLD, CLEAN COMPRESS AND
GET MEDICAL AID.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:NON-FLAMMABLE; BUT SPARKS AND WELDING ARC
MAY IGNITE COMBUSTIBLES DURING USE.
================== Accidental Release Measures ==================
Spill Release Procedures:NOT APPLICABLE. HMIS-PICK UP RODS. SWEEP UP OR
MOP. PLACE RESIDUE IN A CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:REMOVE ANY COMBUSTIBLES FROM WORK
AREA: SPARKS OR WELDING ARC COULD IGNITE NEARBY COMBUSTIBLES.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR WELDING
FUMES OR SUPPLIED AIR RESPIRATOR IN CONFINED SPACES OR WHERE FUME
CONCENTRATION EXCEEDS REGULATORY LIMITS.
Ventilation:USE MECHANICAL OR LOCAL EXHAUST OR BOTH TO MAINTAIN LEVELS
OF FUMES BELOW REGULATORY LIMITS.
Other Protective Equipment:CLOTHING TO PROTECT ENTIRE BODY FROM SPARKS.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:INSOLUBLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE CURRENTLY KNOWN
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:COMPLEX OF OXIDES OF THE INGREDIENTS,
AS WELL AS CARBON MONOXIDE AND CARBON DIOXIDE, OZONE, NITROGEN
OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:AMMONIUM PYRROLIDINE DITHIOCARBAMATE, A18210
Resp. Party Other MSDS Num.:ACC 01395
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:1-PYRROLIDINECARBODITHIOIC ACID, AMMONIUM SALT
EINECS/ELINCS: 225-834-4.
CAS:5108-96-3
Fraction by Wt: 100%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: CAUSES IRRITATION. SKIN:
CAUSES IRRITATION. INGESTION: INGESTION OF LARGE AMOUNTS MAY CAUSE
GASTROINTESTINAL IRRITATION. THE TOXICOLOGICAL PROPERTIES OF THIS
SUBSTANCE HAVE NOT BEEN FULLY INVESTIGATED. INHALATION: MAY CAUSE
RESPIRATORY TRACT IRRITATION. LOW HAZARD FOR USUAL INDUSTRIAL
HANDLING. THE TOXICOLOGICAL PROPERTIES OF THIS SUBSTANCE HAVE NOT
BEEN FULLY INVESTIGATED. CHRONIC: NO INFORMATION FOUND.
Explanation of Carcinogenicity:CAS# 518-96-3: NOT LISTED BY ACGIH,
IARC, NIOSH, NTP, OR OSHA.
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:EYES: IMMED FLUSH W/PLENTY OF WATER FOR AT LST 15 MINS,
OCCASIONALLY LIFTING UPPER & LOWER LIDS. GET MED AID. SKIN: FLUSH
W/PLENTY OF SOAP & WATER FOR AT LST 15 MINS WHILE REMOVING CONTAMD
CLOTHING &SHOES. GET MED AID IF IRRITATION DEVELOPS/PERSISTS.
WASH CLTHG BEFORE REUSE. INGEST: IF VICTIM IS CONSCIOUS & ALERT,
GIVE 2-4 CUPFULS OF MILK/WATER. NEVER GIVE ANYTHING BY MOUTH TO
UNCON PERSON. GET M ED AID. INHAL: REMOVE FROM EXPOSURE TO FRESH
AIR IMMED. IF NOT BRTHG, GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE
OXYG. GET MED AID IF COUGH/OTHER SYMPTOMS (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:CALC
Lower Limits:NOT AVAIL
Upper Limits:NOT AVAIL
Extinguishing Media:IN CASE OF FIRE, USE WATER, DRY CHEMICAL, CHEMICAL
FOAM, OR ALCOHOL-RESISTANT FOAM. USE AGENT MOST APPROPRIATE TO
EXTINGUISH FIRE.
Fire Fighting Procedures:AS IN ANY FIRE, WEAR SELF-CONTAINED BREATHING
APPARATUS IN PRESSURE-DEMAND, NIOSH (APPROVED OR EQUIVALENT), AND
FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:DURING FIRE, IRRITATING & HIGHLY TOXIC
GASES MAY BE GENERATED BY THERMAL DECOMP/COMBUST. THIS MATL IS
SUFFICIENT QUANTITY & REDUCED PARTICLE SIZE IS CAPABLE OF CREATING
A DUST EXPLOSION.
================== Accidental Release Measures ==================
Spill Release Procedures:GENERAL INFORMATION: USE PROPER PERSONAL
PROTECTIVE EQUIPMENT AS INDICATED IN EXPOSURE CONTROLS, PERSONAL
PROTECTION (SECTION 8). SPILLS/LEAKS: VACUUM/SWEEP UP MATERIAL &
PLACE INTO SUITABLE DISPOSAL CONTAINER. CLEAN UP SPILLS
IMMEDIATELY, OBSERVING PRECAUTIONS IN PROECTIVE EQUIPMENT SECTION.
AVOID GENERATING DUSTY CONDITIONS. PROVIDE VENTILATION.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP FROM
CONTACT WITH OXIDIZING MATERIALS. KEEP CONTAINERS TIGHTLY CLOSED.
DO NOT EXPOSE TO AIR. STORE BELOW 50C.
Other Precautions:USE WITH ADEQUATE VENTILATION. MINIMIZE DUST
GENERATION & ACCUMULATION. AVOID CONTACT W/SKIN & EYES. AVOID
INGESTION AND INHALATION: STORE PROTECTED FROM AIR. WASH CLOTHING
BEFORE REUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW OSHA RESPIRATOR REGULATIONS FOUND IN
29CFR 1910.134 OR EUROPEAN STANDARD EN 149. ALWAYS USE A NIOSH OR
EUROPEAN STANDARD EN 149 APPROVED RESPIRATOR WHEN NECESSARY.
Ventilation:FACILITIES STORING OR UTILIZING THIS MATERIAL SHOULD BE
EQUIPPED WITH EYEWASH FACILITY & SFTY SHOWER. USE ADEQUATE VENT TO
KEEP AIRBORNE CONCENTRATIONS LOW.
Other Protective Equipment:EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA . WEAR APPROPRIATE PROTECTIVE CLOTHING TO MINIMIZE CONTACT
WITH SKIN.
Work Hygienic Practices:WASH CLOTHING BEFORE REUSE.
Supplemental Safety and Health
FIRST AID PROC: APPEAR. NOTES TO PHYS: TREAT SYMPTOMATICALLY &
SUPPORTIVELY. SARA TITLE III: IN THIS PROD ARE LISTED AS PRIORITY
POLLUTANTS UNDER CWA. NONE OF CHEMICALS IN THIS PROD ARE LISTED AS
TOXI C POLLUTANTS UNDER CWA. OSHA: NONE OF CHEMS IN PROD ARE
CONSIDERED HIGHLY HAZARDOUS BY OSHA.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:=155.C, 311.F
Decomp Temp:=155.C, 311.F
Vapor Pres:NEGLIGIBLE
Solubility in Water:SOLUBLE
Appearance and Odor:YELLOW SOLID. NO ODOR REPORTED.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:STABLE. HOWEVER, MAY DECOMPOSE IF HEATED.
INCOMPATIBLE MATERIALS, EXPOSURE TO AIR. TEMPERATURES ABOVE 55C.
Hazardous Decomposition Products:NITROGEN OXIDES, CARBON MONOXIDE,
OXIDES OF SULFUR, CARBON DIOXIDE.
=================== Toxicological Information===================
Toxicological Information:RTECS#: CAS# 5108-96-3 UNLISTED. LD50/LC50:
NOT AVAILABLE. EPIDEMIOLOGY, TERATOGENICITY, REPRODUCTIVE EFFECTS,
NEUROTOXICITY, MUTAGENICITY: NO INFORMATION FOUND. OTHER STUDIES:
NO DATA AVAILABLE.
===================== Ecological Information =====================
Ecological:EXOTOXICITY, ENVIRONMENTAL FATE, PHYSICAL/CHEMICAL OR OTHER:
NOT AVAILABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE, AND LOCAL REGULATIONS. RCRA D-SERIES MAX CONC OF
CONTAMINANTS: NONE LISTED. RCRA D-SERIES CHRONIC TOX REFERENCE
LEVELS: NONE LISTED. RCRA F, P, & U SERIES: NONE LISTED.
=================== MSDS Transport Information ===================
Transport Information:NO INFORMATION AVAILABLE.
===================== Regulatory Information =====================
SARA Title III Information:SECTION 12B: NONE OF CHEMS ARE LISTED UNDER
TSCA SECTION 12B. SEFTION 302(RQ): NONE OF CHEMS IN MATL HAVE RQ.
SECTION 302 (TPQ): NONE OF CHEMS IN PROD HAVE A TPQ. SARA CODES:
CAS# 5108-96-3: ACUTE, CH RONIC . SECTION 313: NO CHEMS ARE
REPORTABLE. CLEAN AIR ACT: THIS MATL DOES NOT CNTN ANY HAZ AIR
POLLUTANTS. THIS MATL DOES NT CNTN ANY CLASS 1 OZONE DEPLETORS.
THIS MATL DOES NOT CNTN ANY CLASS 2 OZO NE DEPLETORS. OSHA: NONE OF
CHEMS IN PROD ARE LISTED AS HAZ SUBSTANCES UNDER CWA. ONE OF CHEMS
IN PROD ARE LSITED AS PRIORITY POLLUTANTS UNDER CWA. NONE OF
CHEMICALS (SUPDAT)
Federal Regulatory Information:EUROPEAN/INTERNATIONAL REGULATIONS.
EUROPEAN LABELING IN ACCORDANCE WITH EC DIRECTIVE. HAZARD SYMBOLS:
XI. RISK PHRASES: R 36/38 IRRITATING TO EYES AND SKIN. SAFETY
PHRASES: S 24/25 AVOID CONTACT WITH SKIN AND EYES. WGK(WATER
DANGER/PROTECTION). CAS # 5108-96-3: NO INFORMATION FOUND. CANADA
CAS# 5108-96-3 IS LISTED ON CANADA'S DSL/NDSL LIST. THIS PRODUCT
HAS WHMIS CLASSIFICATION OF D2B. CAS# 5108- 96-3 IS NOT LISTED ON
CANADA'S INGREDIENT DISCLOSURE LIST.
State Regulatory Information:CAS# 5108-96-3 IS NOT PRESENT ON STATE
LISTS FROM CA, PA, MN, MA, FL, OR NJ. CALIFORNIA NO SIGNIFICANT
RISK LEVEL: NONE OF CHEMICALS IN THIS PRODUCT ARE LISTED.
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:POTASSIUM CHLORIDE SOLUTION 9.5% W/V, 51290
CAGE:0E6V4
CAGE:0E6V4
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM CHLORIDE
CAS:7447-40-7
RTECS #:TS8050000
Fraction by Wt: 30%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: MATRIX
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:LARGE DOSES BY MOUTH CAN CAUSE GASTRO-
INTESTINAL IRRITATION AND CIRCULATORY PROBLEMS. TARGET ORGANS:
STOMACH AND BLOOD.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMEDIATELY . INHAL: REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE OXYGEN/ARTIFICIAL RESPIRATION) . EYES: WASH
WITH WATER FOR AT LEAST 15 MINUTES. SKIN: WASH EXPOSED PARTS W ITH
WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH SPILL AREA WITH COPIOUS AMOUNTS OF
WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:WARNING! CAUSES EYE IRRITATION. DO NOT
GET IN EYES. DO NOT HANDLE UNTIL THE MANUFACTURER'S SAFETY
PRECAUTIONS HAVE BEEN READ & UNDERSTOOD.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NOT APPLICABLE.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:ODORLESS AND COLORLESS LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
VIOLENT REACTION WITH BRF3, (H2SO4 + MNO4).
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS .
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:186A128, 7-STAR ACE TONE LATEX SEMI-GLOSS C
CAGE:ACEHA
CAGE:ACEHA
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL. VP: 0.1.
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 2%
OSHA PEL:50 PPM, C
ACGIH TLV:50 PPM, VAPOR, C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:1-PROPANOL, 2-AMINO-2-METHYL-;
(2-AMINO-2-METHYL-1-PROPANOL). VP: 0.8.
CAS:124-68-5
RTECS #:UA5950000
Fraction by Wt: <0.5%
OSHA PEL:20 PPM (MFR)
ACGIH TLV:10 PPM (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IN A CONFINED AREA VAPORS IN
HIGH CONCENTRATION ARE ANESTHETIC. IRRITANT TO SKIN AND UPPER
RESPIRATORY SYSTEM. OVEREXPOSURE MAY RESULT IN LIGHTHEADEDNESS AND
STAGGERING GAIT.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:CHRONIC PROBLEMS WITH RESPIRATORY
SYSTEM MAY BE AGGRAVATED BY EXPOSURE TO VAPORS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM EXPOSURE, RESTORE BREATHING. KEEP WARM AND
QUIET. SKIN: WASH AFFECTED AREAS THOROUGHLY WITH SOAP AND WATER.
REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE RE-USE. EYES: FLUSH
WITH WATER FOR AT LEAST 15 MINUTES. GET MEDICAL ATTENTION. INGEST:
CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:199F,93C
Extinguishing Media:ALCOHOL FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER SPRAY MAY NOT BE EFTIVE. WATER MAY BE USED TO COOL CLSD
CNTNRS TO PVNT PRESS BUILD-UP (SUPP DATA)
Unusual Fire/Explosion Hazard:EXTREME HEAT MAY CAUSE CLOSED CONTAINERS
TO BURST.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
TRANSFER ONLY TO APPROVED CONTAINERS WITH COMPLETE AND APPROPRIATE
LABELING. DOL STORGE CATEGORY - 3B.
Other Precautions:DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF
CHILDREN. USE ONLY WITH ADEQUATE VENTILATION. AVOID BREATHING VAPOR
AND SPRAY MIST. AVOID CONTACT WITH SKIN AND EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, WEAR RESPIRATORY DEVICE APPROVED
BY NIOSH/MSHA.
Ventilation:LOCAL EXHAUST PREFERABLE, GENERAL EXHAUST ACCEPTABLE BELOW
TLV. REFER TO OSHA STDS. 1910.94, 1910.107, 1910.108.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC:AND POSSIBLE AUTO IGNITION OR EXPLOSION WHEN EXPOSED TO
EXTREME HEAT.
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:1.22
pH:8.5-9
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:66.52
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:EXTREME HEAT AND OPEN FLAME.
Hazardous Decomposition Products:BY FIRE: CO AND CO2.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS. DISPOSE OF I/A/W FEDERAL, STATE AND
LOCAL REGULATIONS REGARDING POLLUTION.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:AC420
CAGE:IO264
CAGE:IO264
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM SULFITE (2:1)
CAS:7757-83-7
RTECS #:WE2150000
Fraction by Wt: 5%
Ingred Name:HYDROQUINONE
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: 5-15%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: POSSIBLE IRRITATION. CHRONIC:
DERMATITIS, DIZZINESS, NAUSEA.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:IRRITATION.
Medical Cond Aggravated by Exposure:SKIN SENSITIVITY.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O2/ARTF)
. EYES: IRRIGATE FOR AT LEAST 15 MINUTES. SKIN: WASH CONTACT AREAS
IMMEDIATELY WITH WATER. INGEST: GET MEDICAL ADVICE.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT APPLICABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH WITH LARGE QUANTITIES OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN SEALED CONTAINERS AS PROVIDED,
IN COOL DRY PLACE.
Other Precautions:KEEP AWAY FROM CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:MECHANICAL (GENERAL): RECOMMENDED.
Other Protective Equipment:RUBBER APRON FOR LARGE QUANTITIES.
Work Hygienic Practices:AVOID USING IN UNVENTILATED ROOM. KEEP AWAY
FROM CHILDREN.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Vapor Density:CA. 6
Spec Gravity:1.080
Solubility in Water:TOTAL
Appearance and Odor:CLEAR, AQUEOUS SOLUTION.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, ACIDS, ALKALIS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NOT APPLICABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:USE ABSORBENT MATERIAL AND BURY IN AUTHORIZED
LANDFILL. DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS .
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:7381/BL979
CAGE:88236
CAGE:88236
============= Composition/Information on Ingredients =============
Ingred Name:COBALT (SARA III)
CAS:7440-48-4
RTECS #:GF8750000
OSHA PEL:0.1 MG/M3;AS CO
ACGIH TLV:0.05 MG/M3;DUST 9293
===================== Hazards Identification =====================
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
======================= First Aid Measures =======================
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
===================== Fire Fighting Measures =====================
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
================== Accidental Release Measures ==================
======================Handling and Storage ======================
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
SOURCE OF DATA-MIL HANDBOOK 600-1 SEP 76.SAFETY & HEALTH DATA DEVELOPED
BY DGSC-STF.
================== Physical/Chemical Properties ==================
HCC:A2
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-IN ACCORDANCE WITH
DOD REGULATIONS AND FEDERAL,STATE & LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CO-211-3 ( PRODUCT CODE 032107-05)
Preparer's Name:DELMAR BEIGHT
CAGE:0FGH2
CAGE:0FGH2
Contract Num:SP0490-95-D-4037
CAGE:0VYG8
============= Composition/Information on Ingredients =============
Ingred Name:COBALT
CAS:7440-48-4
RTECS #:GF8750000
Minumum % Wt:20.
Maxumum % Wt:50.
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.02 MG/M3
Ingred Name:NICKEL
CAS:7440-02-0
RTECS #:QR5950000
Minumum % Wt:20.
Maxumum % Wt:50.
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:CHROMIUM
CAS:7440-47-3
RTECS #:GB4200000
Minumum % Wt:20.
Maxumum % Wt:50.
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ALUMINIUM
CAS:7429-90-5
RTECS #:BD0330000
Minumum % Wt:5.
Maxumum % Wt:20.
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): UNKNOWN.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:REPEATED OVEREXPOSURE: MAY CAUSE
SENSITIZATION IN SUSCEPTIBLE INDIVIDUALS. CHRONIC EXPOSURE TO THE
EYE CAN CAUSE CORNEAL DAMAGE, POLYCYTHEMIA, HYPERPLASIA OF THE
THYROID GLAND, & DAMAGE TO THE ALPHA CELLS OF THE PANCREAS.
REPEATED INHALATION MAY CAUSE EMPHYSEMA OR PULMONARY FIBROTIC
DISEASE. CHRONIC SKIN CONTACT MAY SPREAD TO THE WHOLE BODY WITH
LESIONS, ITCHING, SORENESS, BURNING SENSATION & RED NESS.
Explanation of Carcinogenicity:NICKEL IS LISTED AS A PROBABLE HUMAN
CARCINOGEN. CHROMIUM IS LISTED AS A HUMAN CARCINOGEN. NICKEL &
CHROMIUM HAVE BEEN DETERMINED TO CAUSE CANCER IN EXPERIMENTAL
ANIMALS (IARC, NTP).
Effects of Overexposure:SKIN-MAY CAUSE ALLERGIC DERMATITIS, WITH
REDNESS & PAPULAR FORMATION IN SUSCEPTIBLE INDIVIDUALS, WHICH
USUALLY OCCURS IN THE FOLDS OF THE SKIN. MAY CAUSE ULCERS
PROGRESSING TO DRY & SCALY SKIN, FEVER . EYE-MAY CAUSE IRRITATION,
EXPERIENCED AS REDNESS & EXCESS REDNESS OF THE CONJUNCTIVA.
SWALLOWING-MAY CAUSE NAUSEA, ABDOMIAL PAIN, VOMITING, DIARRHEA, CNS
DEPRESSION, & BURNING SENSATION. INHALATION- MAY CAUSE RESPIRATORY
TRACT IRRITATION, WITH CHEST PAIN, VOMITING, DIARRHEA, BURNING
SENSATION, & CNS DEPRESSION. MAY ALSO CAUSE INTERSTITIAL
PNEUMONITIS & SENSITIZATION OF THE RESPIRATORY TRACT IN SU
SCEPTIBLE INDIVIDUALS.
Medical Cond Aggravated by Exposure:BREATHING OF DUST MAY AGGRAVATE
ASTHMA AND INFLAMMATORY OR FIBROTIC PULMONARY DISEASE. MAY ALSO
AGGRAVATE AN EXISTING DERMATITIS.
======================= First Aid Measures =======================
First Aid:SWALLOWING-GIVE AT LEAST 2 GLASSES OF MILK OR WATER. INDUCE
VOMITING, UNLESS PATIENT IS UNCONSCIOUS. CALL A PHYSICIAN.
SKIN-WASH THOROUGHLY WITH SOAP AND WATER. INHALATION-REMOVE TO
FRESH AIR. GIVE AR TIFICIAL RESPIRATION IF NOT BREATHING. OXYGEN
MAY BE GIVEN IF NECESSARY. CALL A PHYSICIAN. EYES-FLUSH THOROUGHLY
WITH PLENTY OF WATER. IF DISCPMFORT PERSISTS, SEEK MEDICAL
ATTENTION, PREFERABLY AN OPT HALMOLOGIST.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:USE SPECIAL DRY POWDER METAL EXTINGUISHING MATERIAL
TO EXTINGUISH METAL FIRES. USE APPROPRIATE EXTINGUISHER TO
EXTINGUISH COMBUSTABLE MATERIALS THAT MAY BE IGNITED BY THERMAL
FLAME.
Fire Fighting Procedures:CONSULT AND COMPLY WITH ANSI Z49.1 SAFETY IN
WELDING AND CUTTING, NFPA51B STANDARD FOR FIRE PREVENTION IN USE OF
CUTTING AND WELDING PROCESSES. NFPA51 OXYGEN-FUEL GAS SYSTEMS FOR
WELDING AND CUTTING, AND NFPA58 STANDARD FOR THE STORAGE AND
HANDLING OF LIQUIFIED PETROLEUM GASES.
Unusual Fire/Explosion Hazard:AIRBORNE DUST PARTICLES, ESPECIALLY METAL
DUST, AND ACCUMULATION OF SUCH SHOULD BE TREATED AS EXPLOSIVES. TO
MINIMIZE DANGER FROM DUST EXPLOSIONS, ADEQUATE VENTILATION SHOULD
BE PROVIDED TO SPRAY BOOT H IN ACCORDANCE WITH AMERICAN WELDING
SOCIETY PUBLICATION AWSC2.1-73, AND ACGIH PUBLICATION "INDUSTRIAL
VENTILATION".
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT TO PROTECT AGAINST
HAZARDS AND DISPOSE OF PER WASTE DISPOSAL METHOD.
======================Handling and Storage ======================
Other Precautions:CAUTION: WHEN THERMAL SPRAYING - ELECTRICITY CAN
CAUSE FATAL SHOCK! DO NOT TOUCH LIVE ELECTRICAL PARTS! ARC RAYS CAN
BURN EYES AND SKIN! WEAR RECOMMENDED EYE AND BODY PROTECTION.
FUMES, GAS, & DUST CA N HARM YOUR HEALTH. PROVIDE ENOUGH
VENTILATION AND WEAR RESPIRATORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DEPENDS UPON SPECIFIC USE, CONDITION, AND
LOCATION. IF THERE IS DUSTINESS, WEAR RESPIRATOR SELECTED PER OSHA
1910.134, AND OSHA 29 CFR 1910.252 AND ANSI Z49.1
Ventilation:LOCAL DUST PICK UP AND VENTILATION RECOMMENDED.
Other Protective Equipment:SEE ANSI Z49.1, ANSI Z87.1, ANSI Z88.2 FOR
Supplemental Safety and Health
CAUTION: WHEN THERMAL SPRAYING-ELECTRICITY CAN CAUSE FATAL SHOCK! DO
NOT TOUCH LIVE ELECTRICAL PARTS! ARC RAYS CAN BURN EYES AND SKIN!
WEAR RECOMMENDED EYE ANDBODY PROTECTION. FUMES, GAS, AND DUST CAN
HARM YOUR HEALTH. PROVIDE ENOUGH VENTILATION AND WEAR RESPIRATORS.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NONE
Vapor Density:N/VOLATILE
Appearance and Odor:DUSTY DARK GRAY POWDER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
Hazardous Decomposition Products:WHEN THERMAL SPRAYING, DECOMPOSITION
PRODUCTS WILL VARY WITH OPERATING CONDITIONS. REASONABLY EXPECTED.
DECOMPOSITION PRODUCTS OF NORMAL OPERATION FROM THIS THERMAL SPRAY
POWDER (OXIDES, SUB-OXIDES, ETC
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE PERS LOCAL, STAET, AND FEDERAL
REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:PROPER SHIPPING NAME: METAL ALLOY POWDER NOI ITEM
136500 SUB 1.
===================== Regulatory Information =====================
SARA Title III Information:7440-48-4, COBALT, <50 PERCENT BY WEIGHT.
7440-02-0, NICKEL, <50 PERCENT BY WEIGHT . 7440-47-3, CHROMIUM, <50
PERCENT BY WEIGHT.
Federal Regulatory Information:ALL INGREDIENTS IN THIS PRODUCT ARE
LISTED IN THE T.S.C.A. INVENTORY.
State Regulatory Information:PROP 65 (CARCINOGEN): WARNING: THIS
PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO
CAUSE CANCER. CAS #7440-02-0, NICKEL; CAS #7440-47-3, CHROMIUM.
======================= Other Information =======================
| 0 |
gloves_not_mandatory
|
=======================================================
Product ID: TEC FLUX,516-714
Cage: 91874
=======================================================
Contractor Summary
=======================================================
Cage: 91874
Cage: 26290
=======================================================
Ingredients
=======================================================
% Wt: <50
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50 (ORAL, RAT) IS NOT KNOWN.
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: TARGET ORGANS:EYE, SKIN, RESPIRATORY & GI TRACTS.
ACUTE- INHALATION OF PRODUCT/DECOMPOSITION PRODUCTS DOES NOT POSE A
SIGNIFICANT HEALTH RISK IF USED AS INSTRUCTED. CAN CAUSE SKIN
IRRITATION/BURNS. CA N CAUSE SEVERE EYE IRRITATION/CORNEAL INJURY. TOXIC IF
INGESTED. CAN CAUSE PAIN, CONVULSION, KIDNEY DAMAGE. CHRONIC- UNK
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: SEVERE IRRITATION, BURNS, PAIN, COUGH,
TEARING, CORNEAL DAMAGE, ULCERATION, CRAMPS, NAUSEA, VOMITING, DIARRHEA,
BLINDNESS, SHORTNESS OF BREATH, CHILLS, FEVER, CHEST TIGHTNESS
Medical Cond Aggravated By Exposure: PERSONS WITH PRE-EXISTING SKIN DISORDERS,
EYE PROBLEMS OR IMPAIRED GASTROINTESTINAL OR RESPIRATORY FUNCTION MAY BE MORE
SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.
First Aid: GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:MOVE TO FRESH AIR.
PROVIDE CPR/OXYGEN IF NEEDED. EYES:IMMEDIATELY FLUSH WITH WATER FOR 15
MINUTES. HOLD EYELIDS OPEN. SKIN:WASH WITH WATER FOR AT LEAST 5 MINTES.
ORAL:DO NOT INDUCE VOMITING. KEEP SUBJECT WARM & AT REST. SEEK IMMEDIATE
MEDICAL ATTENTION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: WEAR APPROPRIATE PROTECTIVE EQUIPMENT. AVOID CONTACT
WITH EYES, SKIN AND MUCOUS MEMBRANES. DILUTE SPILL AND WASH DOWN THE DRAIN
WITH WATER.
Neutralizing Agent: SODIUM BICARBONATE, LIME, SODA ASH
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS. CONTRACT WITH A LICENSED WASTE DISPOSAL SERVICE.
Handling And Storage Precautions: STORE IN COOL, DRY PLACE, AWAY FROM
INCOMPATIBLES. KEEP OUT OF REACH OF CHILDREN.
Other Precautions: AVOID BREATHING FUMES. DO NOT GET IN EYES, ON SKIN OR ON
CLOTHING. WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING OR DRINKING.
REMOVE CONTAMINATED CLOTHING PROMPTLY. LAUNDER BEFORE REUSE.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONE
Lower Limits: NOT RELEVANT
Upper Limits: NOT RELEVANT
Extinguishing Media: WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL FOR
SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED CONTAINERS.
Fire Fighting Procedures: WEAR FULL PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS WITH FULL FACEPIECE OPERATED IN POSITIVE
PRESSURE MODE.
Unusual Fire/Explosion Hazard: HAZARDOUS COMPONENTS MAT BE EMITTED.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE NORMALLY REQUIRED. FOR SYMPTOMS OF OVER EXPOSURE,
WEAR NIOSH-APPROVED RESPIRATOR. IN EMERGENCY, WEAR A NIOSH-APPROVED
POSITIVE-PRESSURE SELF-CONTAINED BREATHING APPARATUS.
Ventilation: USE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP FUME OR VAPOR
LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment: EYEBATH, WASHING FACILITY, SAFETY SHOWER, APRON
Work Hygienic Practices: OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: C1
NRC/State LIC No: NOT RELEVANT
B.P. Text: 229F,109C
M.P/F.P Text: UNKNOWN
Decomp Text: UNKNOWN
Vapor Pres: UNKNOWN
Vapor Density: UNKNOWN
Spec Gravity: 1.55
Viscosity: NOT RELEVANT
Solubility in Water: SOLUBLE
Appearance and Odor: RED LIQUID - MILD ODOR
Percent Volatiles by Volume: 37
Corrosion Rate: UNKNOWN
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: ELEVATED TEMPERATURES
Materials To Avoid: POTASSIUM + ALUMINUM BROMIDE; POTASSIUM CHLORATE; AMMONIUM
NITRATE; IODINE PENTAFLUORIDE; BROMINE TRIFLUORIDE
Hazardous Decomposition Products: AMMONIUM CHLORIDE, ZINC CHLORIDE, ZINC OXIDE,
HYDROGEN CHLORIDE
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 7620
Product ID: TEC FLUX,516-714
Review Date: 08/27/1998
Tech Entry NOS Shipping Nm: INORGANIC ZINC SALTS
Radioactivity: NOT RELEVANT
Net Unit Weight: UNKNOWN
Multiple KIT Number: 0
Review IND: Y
Additional Data: PROPER SHIPPING NAME, UN ID NUMBER, PACKING GROUP, HAZARD
CLASS PER MSDS. MAXIMUM ALLOWED BY CARGO A IR: 60 LITERS.
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: DWG
Symbols: G
DOT Proper Shipping Name: CORROSIVE LIQUIDS, N.O.S.
Hazard Class: 8
UN ID Num: UN1760
DOT Packaging Group: III
Label: CORROSIVE
Special Provision: T7
Non Bulk Pack: 203
Bulk Pack: 241
Max Qty Pass: 5 L
Max Qty Cargo: 60 L
Vessel Stow Req: A
Water/Ship/Other Req: 40
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ESH
IMO Proper Shipping Name: CORROSIVE LIQUID, N.O.S. o
IMDG Page Number: 8147
UN Number: 1760
UN Hazard Class: 8
IMO Packaging Group: I/II/III
Subsidiary Risk Label: -
EMS Number: 8-15
MED First Aid Guide NUM: 760
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: HKW
IATA UN ID Num: 1760
IATA Proper Shipping Name: CORROSIVE LIQUID, N.O.S. *
IATA UN Class: 8
IATA Label: CORROSIVE
UN Packing Group: III
Packing Note Passenger: 818
Max Quant Pass: 5L
Max Quant Cargo: 60L
Packaging Note Cargo: 820
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: HKW
AFI Symbols: *
AFI Proper Shipping Name: CORROSIVE LIQUID, N.O.S.
AFI Hazard Class: 8
AFI UN ID NUM: UN1760
AFI Packing Group: III
Special Provisions: P5
Back Pack Reference: A12.3
=======================================================
HAZCOM Label
=======================================================
Product ID: TEC FLUX,516-714
Cage: 91874
Company Name: LUCAS-MILHAUPT INC A HANDY & HARMAN CO
Street: 5656 SOUTH PENNSYLVANIA AVENUE
Zipcode: 53110
Label Required IND: Y
Date Of Label Review: 08/27/1998
Status Code: C
MFG Label NO: UNKNOWN
Label Date: 08/27/1998
Origination Code: F
Skin Protection IND: YES
Signal Word: WARNING
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: TARGET ORGANS:EYE, SKIN, RESPIRATORY & GI TRACTS.
ACUTE- INHALATION DOES NOT POSE A SIGNIFICANT HEALTH RISK IF USED AS
INSTRUCTED. CAN CAUSE SKIN BURNS, SEVERE EYE IRRITATION/CORNEAL INJURY. TOXIC
IF INGESTED. CAN CAUSE KIDNEY DAMAGE. CHRONIC- UNKNOWN. STORE AWAY FROM
INCOMPATIBLES. DILUTE SPILL & WASH DOWN DRAIN WITH WATER. FIRST AID- GET
MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:MOVE TO FRESH AI R. PROVIDE
CPR/OXYGEN IF NEEDED. EYES:IMMEDIATELY FLUSH WITH WATER FOR 15 MINUTES. HOLD
EYELIDS OPEN. SKIN:WASH WITH WATER FOR AT LEAST 5 MINTES. ORAL:DO NOT INDUCE
VOMITING. KEEP SUBJECT WARM & AT RE ST. SEEK IMMEDIATE MEDICAL ATTENTION.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:5R307, DEVELOPER DOCUPRINT 390, 1075, 1090, (SUPDAT)
CAGE:0E6G9
CAGE:0E6G9
CAGE:26921
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE, ACRYLATE COPOLYMER
CAS:25213-39-2
Fraction by Wt: >90%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 5-10%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:PYRIDINIUM, 1-HEXADECYL-, CHLORIDE; (QUATERNARY AMMONIUM
SALT AND INGREDIENT 7)
CAS:123-03-5
RTECS #:UU4900000
Fraction by Wt: <2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DIMETHYLDIOCTADECYLAMMONIUM METHYL SULFATE; (QUATERNARY
AMMONIUM SALT)
CAS:3843-16-1
Fraction by Wt: <2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT: COMPLY W/EPA TESTING PROTOCOL. TEST TONER WAS TEN
TIMES MORE RESPIRABLE THAN COMMERCIALLY AVAIL XEROX (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: TONER & WOULD NOT BE FUNCTIONALLY SUITABLE FOR XEROX
EQUIPMENT.
RTECS #:9999999ZZ
REQUIRED. FOR MORE INFO, CONTACT XEROX.
RTECS #:9999999ZZ
Ingred Name:CARRIER (CONTAINING INGREDIENT 2)
Fraction by Wt: 95-100%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:IRON; (STEEL POWDER)
CAS:7439-89-6
RTECS #:NO4565500
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TONER (CONTAINING INGREDIENTS 4-7. NOTE: DEVELOPERS LABELED
1075/1090/4050/4090/4650 CONTAIN ONLY INGREDIENT 6 (<5%))
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL, RAT) >10 G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:MINIMAL RESP TRACT IRRIT MAY OCCUR AS
W/EXPOS TO LARGE AMTS OF ANY NON-TOXIC DUST. ADDNL INFO: NO
SIGNIFICANT EFTS ON FETAL DEVELOPMENT (RATS). SUBCHRONIC INHAL
(RATS): NO ADVERSE EFTS OTHER THAN THOS E DUE TO "LUNG OVERLOADING"
(DEFINED BELOW). RSLTS OBTAINED FROM XEROX SPONSORED CHRONIC TONER
INHAL (EFTS OF OVEREXP)
Explanation of Carcinogenicity:CARBON BLACK: IARC MONOGRAPHS, VOL 65,
PG 149, 1996:GROUP 2B.
Effects of Overexposure:HLTH HAZ: STUDY, DEMONSTRATED NO LUNG CHANGE IN
RATS FOR LOWEST (1MG/M3) EXPOS LEVEL (IE, LEVEL MOST RELEVANT TO
POTNTL HUMAN EXPOS). VERY SLIGHT DEGREE OF FIBROSIS WAS NOTED IN
25% OF ANIMALS AT MIDD LE (4MG/M3) EXPOS LEVEL, WHILE SLIGHT DEGREE
OF FIBROSIS WAS NOTED IN ALL ANIMALS AT HIGHEST (16MG/M3) EXPOSURE
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE WHEN USED AS DESCRIBED BY
PRODUCT LITERATURE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN: WASH
WITH SOAP AND WATER. INHALATION: REMOVE FROM EXPOSURE. INGESTION:
DILUTE STOMACH CONTENTS WITH SEVERAL GLASSES OF WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:IF SPILLED, SWEEP UP OR VACUUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE. AVOID PROLONGED INHALATION OF
EXCESSIVE DUST.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN XEROX
EQUIPMENT. USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:FOR USE OTHER THAN NORMAL CUSTOMER OPERATING
PROCS (SUCH AS BULK TONER PROCESSING FACILITIES), ANSI APPRVD (ING
10)
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO: 4050, 4090, 4450, 4530, 4650, 5388, 5680,
5892, DOCUTECH MODEL 90. EFTS OF OVEREXP: LEVEL. THESE FINDINGS ARE
ATTRIBUTED TO "LUNG OVERLOADING," A GENERIC RESPONSE TO EXCESSIV E
AMTS OF ANY DUST RETAINED IN LUNGS FOR PRLNGD PERIOD. THIS STUDY
WAS CONDUCTED USING SPECIAL TEST TONER TO (ING 8)
================== Physical/Chemical Properties ==================
Spec Gravity:7 (H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK GRANULAR; FAINT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION MAY BE TOXIC.
AVOID BREATHING SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS MATERIAL IS NOT A HAZARDOUS WASTE ACCORDING
TO FEDERAL REGULATION 40 CFR 261 WHEN DISPOSED. STATE & LOCAL WASTE
DISPOSAL REQUIREMENTS MAY HOWEVER, BE MORE RESTRICTIVE. CONSULT
W/APPROPRIATE FEDER AL, STATE & LOCAL AUTHORITIES FOR SPECIFIC
INFO.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:15560-1-2 TO 15564-1-2 SOFT CARE INDUSTRIAL SOAP
Preparer's Name:TERRY A MEYERS
CAGE:0U826
CAGE:0U826
CAGE:32204
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIUM LAURYL SULFATE
CAS:2235-54-3
RTECS #:WT0825000
Fraction by Wt: 7-12%
Ingred Name:AMMONIUM LAURYL ETHER SULFATE
CAS:32612-48-9
RTECS #:MD0100000
Fraction by Wt: 6-12%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 80-90%
Ingred Name:SODIUM CITRATE
CAS:6132-04-3
Fraction by Wt: 2-4%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15-20 MINS. OBTAIN MEDICAL ATTENTION
IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:NORMAL FIRE FIGHTING PROCEDURES MAY BE USED.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP/SCRAPE UP & CONTAINERIZE. RINSE AFFECTED
AREA THOROUGHLY W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Ventilation:GENERAL ROOM VENTILATION IS ADEQUATE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>200F
Spec Gravity:1.03
pH:6.3
Solubility in Water:COMPLETE
Appearance and Odor:DARK BLUE, CLEAR LIQUID W/FRAGRANT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:FREEZING
Hazardous Decomposition Products:WHEN EXPOSED TO FIRE, PRODUCES NORMAL
PRODUCTS OF COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:SUPER HUSKY 303 TOILET BOWL CLEANER
CAGE:CANBE
CAGE:CANBE
============= Composition/Information on Ingredients =============
Ingred Name:QUATERNARY AMMONIUM COMPOUNDS, BENZYL-C
12-C16-ALKYLDIMETYL, CHLORIDES; (N-ALKYL DIMETHYLBENZYL AMMONIYUM
CHLORIDE)
CAS:68424-85-1
RTECS #:UZ2995000
Fraction by Wt: 0.05%
Ingred Name:HYDROCHLORIC ACID (SARA III)
CAS:7647-01-0
RTECS #:MW4025000
Fraction by Wt: 23%
OSHA PEL:5 PPM, C
ACGIH TLV:5 PPM, C
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: RAPIDLY CAUSES CHEMICAL BURNS
TO SKIN & EYES. MAY CAUSE PERMANENT DAMAGE. CHRONIC: NO INFORMATION
ON CHRONIC HEALTH HAZARD IS CURRENTLY AVAIALBLE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:IRRITATION, BURNING OF SKIN, MUCOUS MEMBRANES
AND RESPIRATORY SYSTEM. CORROSIVE ACTION ON CONTACTED SURFACE.
Medical Cond Aggravated by Exposure:PERSONS WITH RESPIRATORY AILMENTS
MAY FIND THOSE CONDITIONS AGGRAVATED DURING PERSONAL USE OF THIS
PRODUCT.
======================= First Aid Measures =======================
First Aid:EYE: IMMED FLUSH W/PLENTY OF WATER FOR @ LEAST 15 MIN. HOLD
EYE LIDS OPEN WHILE FLUSHING. GET MED ATTN. SKIN: FLUSH SKIN IMMED
WITH COOL WATER. WASH WITH SOAP & WATER. REMOVE CONTAM CLTHG.
INHAL: REMO VE TO FRESH AIR. GET MEDICAL ATTN. INGEST: DO NOT
INDUCE VOMITING. GIVE MILK, WATER OR EGG WHITES, & GET MEDICAL
ATTENTION IMMEDIATELY. NEVER GIVE ANYTHING BY MOUTH TO UNCON
PERSON. KEEP WARM.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER FOG, CO*2, DRY CHEMICAL
Fire Fighting Procedures:USE WATER SPRAY TO COOL CNTNRS & CONTROL VAPS.
WEAR NIOSH/MSHA APPROVED SCBA & FULL PROT EQUIP .
Unusual Fire/Explosion Hazard:RELEASE OF CORROSIVE HYDROGEN CHLORIDE
GAS MAY RESULT AT ELEVATED TEMPERATURES. REACTS WITH OXIDIZERS,
CYANIDES AND SULFIDES TO FORM POISONOUS GAS. (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR FULL PERSONAL PROTECTIVE EQUIPMENT.
VENTILATE AREA TO DISSIPATE FUMES. CONTAIN SPILL AND COLLECT IN
APPROVED CONTAINERS. RINSE WITH DILUTE BICARBONATE SOLUTION TO
NEUTRALIZE RESIDUE.
Neutralizing Agent:DILUTE ALKALINE SOLUTION.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
USE WITH TOILET BOWL MOP OR APPLICATOR. USE ONLY ACCORDING TO LABEL
DIRECTIONS. DO NOT MIX WITH OTHER CHEMS.
Other Precautions:WEAR RECOMMENDED PROTECTIVE EQUIPMENT. STORE IN COOL
PLACE. KEEP OUT OF REACH OF CHILDREN. AVOID CONTACT WITH SKIN OR
EYES. AVOID BREATHING VAPOR.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE REQUIRED TO MAINTAIN EXPOSURE LEVELS BELOW
ALLOWABLE LIMITS, USE NIOSH/MSHA APPROVED RESPIRATOR FOR HYDROGEN
CHLORIDE GAS OR MIST AS APPLICABLE.
Ventilation:LOCAL EXHAUST: ADEQUATE TO MAINTAIN TLV.
Other Protective Equipment:RUBBER APRON, BOOTS, AND LONG SLEEVES
RECOMMENDED. EMERGENCY EYEWASH AND DELUGE SHOWER .
Work Hygienic Practices:GOOD HOUSEKEEPING PRACTICES APPLY. WASH
THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
EXPLO HAZ: REACTS WITH MOST METALS TO FORM POTENTIALLY EXPLOSIVE
HYDROGEN GAS. WASTE DISPOSAL: TRASH, OR FOR LARGER CONTAINERS,
TRIPLE RINSE AND OFFER FOR RECYCLING. DISPOSAL MUST BE IN
ACCORDANCE WIT H FEDERAL, STATE AND LOCAL REGULATIONS .
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:30 @ 25C
Spec Gravity:1.122 (H*2O=1)
Solubility in Water:COMPLETE
Appearance and Odor:PINK LIQUID/PUNGENT ODOR.
Percent Volatiles by Volume:95
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
METALS. CHLORINE BLEACH - DO NOT MIX WITH OTHER CHEMICALS
Stability Condition to Avoid:CONTACT WITH LIGHT METALS MAY GENERATE
HYDROGEN GAS.
Hazardous Decomposition Products:CHLORINE GAS; HYDROGEN GAS; HYDROGEN
CHLORIDE GAS.
==================== Disposal Considerations ====================
Waste Disposal Methods:FORWARD WASTE MATL TO A FEDERALLY LICENSED HAZ
TREATMENT FACILITY. WASTE OR UNUSED MATL MAY BE RENDERED NON-HAZ BY
NEUTRALIZATION W/DILUTE ALKALINE SOLN. CAUTION: NEVER ADD CONC
ALKALI TO THIS PROD. T RIPLE RINSE CNTNR, WRAP, & DISCARD IN (SUPP
DATA)
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CONFIDENT INTERIOR LATEX SEMI-GLOSS (SUPP D
CAGE:85231
CAGE:59019
CAGE:85231
============= Composition/Information on Ingredients =============
Ingred Name:2-(2-BUTOXYETHOXY)-ETHANOL;(DIETHYLENE GLYCOL MONOBUTYL
ETHER). VP: 0.1
CAS:112-34-5
RTECS #:KJ9100000
Fraction by Wt: 0-5%
OSHA PEL:50 PPM
ACGIH TLV:50 PPM
Ingred Name:ETHYLENE GLYCOL. VP: 0.1
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 0-5%
OSHA PEL:50 PPM, C
ACGIH TLV:50 PPM,VAPOR, C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 5-20%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:SUPP DATA: AT 250 MG/M3 DEVELOPED LUNG CANCER, HOWEVER,
SUCH EXPOSURE LEVELS ARE NOT ATTAINABLE IN WORKPLACE.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: BRTHG VAP/SPRAY MIST. AVOID CNTCT W/SKIN &
EYES. KEEP OUT OF REACH OF CHILDREN. LMTS FOR NIUSANCE (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: DUSTS ARE ACGIH TLV 10 MG/M3 (TDUST), OSHA PEL 15
MG/M3 (TDUST), 5 MG/M3 (RESP).
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRIT OF EYES, SKIN & UPPER
RESP SYS. IN CONFINED AREA VAPS IN HIGH CONC MAY CAUSE HEADACHE,
NAUSEA/DIZZ. CHRONIC: ETHYLENE GLYCOL IS CONSIDERED AN ANIMAL
TERATOGEN. IT HAS BEEN SHOWN TO CAUSE BIRTH DEFECTS IN RATS/MICE
AT HIGH DOSES WHEN GIVEN IN DRINKING WATER/BY GAVAGE. THERE IS NO
EVIDENCE (SUPP DATA)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:REDNESS AND ITCHING OR BURNING SENSATION MAY
INDICATE EYE OR EXCESSIVE SKIN EXPOSURE.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE BREATHING.
KEEP WARM AND QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP
AND WATER. REMOVE CONTAMINATED CLOTHING & LAUNDER BEFORE RE-USE.
EYES: F LUSH EYES WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. GET MEDICAL ATTENTION. INGEST: CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>199F,>93C
Extinguishing Media:CO*2, DRY CHEMICAL, ALCOHOL FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT
EQUIP(F PN). WATER SPRAY MAY BE INEFTIVE. IF WATER IS USED, FOG
NOZZ ARE PREF. WATER MAY BE USED TO COOL CLSD(SUPP DATA)
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO
BUILD-UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNR CLSD WHEN NOT IN USE. TRANS
ONLY TO APPRVD CNTNR W/COMPLETE & APPROP LABELING. DO NOT TAKE
INTERNALLY. USE ONLY W/ADEQ VENT. AVOID (ING 6)
Other Precautions:COATING MAY CONTAIN MATLS CLASSIFIED AS NUISANCE
PARTICULATES, SUCH AS TITANIUM DIOXIDE OR CALCIUM CARBONATE WHICH
MAY BE PRESENT AT HAZ LEVELS ONLY DURING SANDING & ABRADING OF
DRIED FILM. IF NO SPEC DUST ARE LISTED, THE APPLIC (ING 5)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERS EXPOS CAN'T BE CONTROLLED < APPLIC LMTS
BY VENT, WEAR NIOSH/MSHA APPRVD ORG VAP/PARTICULATE RESP. WHEN
SANDING/ABRADING DRIED FILM, WEAR NOISH/MSHA APPRVD DUST/MIST RESP
FOR DUST GENERATED FRO M PROD, UNDERLYING PAINT/ABRASIVE.
Ventilation:LOCAL EXHAUST PREF. GENL EXHST ACCEPTABLE IF EXPOS TO MATLS
IS MAINT < APPLIC LMTS. REFER TO OSHA STDS 1910.94,107,108.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
TRADE NAME/PART #: FINISH, 5273-03 TINT BASE A. FIRE FIGHT PROC: CNTNRS
TO PVNT PRESS BUILDUP & POSS AUTOIGNIT/EXPLOS WHEN EXPOS TO EXTREME
HEAT. HEALTH HAZ: TO INDICATE IT CAUSES BIRTH DEFECTS IN HUM ANS.
PRLNGD OVEREXP TO SOLV ING MAY CAUSE ADVERSE EFTS TO LIVER/URINARY
SYS. RATS EXPOS TO TITANIUM DIOXIDE DUST (ING 4)
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
pH:SUPDAT
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:66-75
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THIS PRODUCT IS NOT HAZARDOUS AS
DEFINED UNDER THE RCRA 40 CFR 261. INCINERATE IN APPROVED FACILITY.
DO NOT INCINERATE CLOSED CONTAINER. DISPOSE OF I/A/W FEDERAL, STATE
AND LOCAL REGULATION S REGARDING POLLUTION.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:13867, COPPER SPECPURE ICP STANDARD SOLUTION (SUPDAT)
CAGE:0JVJ1
CAGE:0JVJ1
============= Composition/Information on Ingredients =============
Ingred Name:COPPER (II) NITRATE, TRIHYDRATE (1:2:3); (COPPER NITRATE)
CAS:10031-43-3
RTECS #:GL7875000
Fraction by Wt: 0.3%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:NITRIC ACID (SARA 302/313) (CERCLA)
CAS:7697-37-2
RTECS #:QU5775000
Fraction by Wt: 5%
OSHA PEL:2 PPM
ACGIH TLV:2 PPM;4 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: BALANCE
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INGEST:MAY CAUSE IMMED PAIN &
BURNS OF MOUTH, THROAT, ESOPHAGUS & GI TRACT. SKIN:MAY CAUSE
REDNESS, PAIN & BURNS, POSS SEV. MAY CAUSE DEEP ULCERS & STAIN SKIN
YELLOW/YELLOW-BROWN COLOR. EYE CONT :VAPS MAY CAUSE IRRIT/DMG.
SPLASHES MAYCAUSE SEV BURNS & PERM DMG. INHAL:MAY CAUSE BRTHG
DFCLTIES (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:LEADING TO PNEUM & PULM EDEMA. SYMPS
INCL COUGHING, CHOKING & IRRIT OF NOSE, THROAT & RESP TRACT.
CHRONIC:INGEST:INGEST OF COPPER SALTS MAY CAUSE RENAL DMG. SKIN
CONT:MAY CAUSE SENSIT RXNS. E YE CONT:NONE KNOWN. INHAL:LONG-TERM
EXPOS MAY CAUSE EROSION OF TEETH.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:EYES:IMMEDIATELY FLUSH W/POTABLE WATER FOR A MINIMUM OF 15
MINUTES, SEEK ASSISTANCE FROM MD . INGEST:DO NOT INDUCE VOMITING.
GIVE LARGE QUANTITIES OF WATER OR MILK, IF AVAILABLE. NEVER GIVE
ANYT HING BY MOUTH TO AN UNCONSCIOUS PERSON.GET MED ATTN IMMED.
SKIN:REMOVE CONTAM CLTHG, FLOOD SKIN W/LG AMTS OF WATER. IF IRRIT
PERSISTS, SEEK MED ATTN. INHAL:ONE SHOULD OBTAIN MED ATTN.
===================== Fire Fighting Measures =====================
Extinguishing Media:NON-COMBUSTIBLE. USE WATER, CARBON DIOXIDE, DRY
CHEMICAL EXTINGUISHING AGENTS, DRY SAND OR DRY GROUND DOLOMITE.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
NO SPECIAL FIREFIGHTING PROCS NEEDED. IF W/OUT RISK, REMOVE MATL
FROM FIRE AREA. COOL CNTNR W/WATER(SUPDAT)
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:WEARING FULL PROTECTIVE EQUIPMENT, COVER SPILL
W/DRY SAND OR VERMICULITE. MIX WELL & CAREFULLY TRANSFER TO A
CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN A COOL, DRY, WELL-VENTILATED AREA.
Other Precautions:CORROSIVE, BURNS SKIN & EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NECESSARY, USE A NIOSH/MSHA APPROVED RESPIRATOR
WITH AN ACID/GAS CARTRIDGE.
Ventilation:LABORATORY FUME HOOD.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . LAB COAT & APRON, FLAME & CHEMICAL (SUPP
DATA)
Work Hygienic Practices:WASH THOROUGHLY AFTER USE.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:1,000 PPM. % VOLAT:NOT HIGHLY VOLATILE. FIRE
FIGHT PROC:FROM MAX DIST. MATLS TO AVOID:CARBIDES, HYDROGEN SULFIDE
& COMBUST ORGANICS. WILL REACT W/THOSE MATL INCOMPAT W/AQ SOLN S.
EYE PROT:& FULL LENGTH FACESHIELD . OTHER PROT EQUIP:RESIST
COVERALLS, & HYGIENIC FACILITIES FOR WASHING.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Spec Gravity:1 (H*2O=1)
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR LIQUID; ODOR OF HNO*3.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NITRIC ACID IS POWERFUL OXIDIZING AGENT & IS INCOMPAT W/MOST SUBSTANCES
ESP STRONG BASES, METALLIC POWDERS, (SUPP DATA)
Stability Condition to Avoid:INCMPATIBLES.
Hazardous Decomposition Products:NO*X, HEAT.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT STATE, LOCAL OR FEDERAL EPA REGULATIONS
FOR PROPER DISPOSAL. RCRA CODE:D002. TSCA REGISTERED:YES, AS
SEPARATE COMPONENTS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:6R139 TONER
CAGE:XEROX
CAGE:XEROX
CAGE:26921
============= Composition/Information on Ingredients =============
Ingred Name:BISPHENOL-A PROPYLENE OXIDE FUMARATE (POLYMER),POLYESTER
RESIN
CAS:39382-25-7
Fraction by Wt: 65-75%
Ingred Name:IRON OXIDE
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 20-30%
Other REC Limits:NONE SPECIFIED
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: <5%
Other REC Limits:3.5 MG/CUM (NIOSH)
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192
Ingred Name:SILICA AMORPHOUS HYDRATED, SILICEOUS EARTH, FUMED SILICA,
COLLOIDAL SILICON DIOXIDE, (SUSPECTED HUMAN CARCINOGEN)
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: <1%
Other REC Limits:20 MPPCF
OSHA PEL:80 MG/CUM (%SIO2+2)
ACGIH TLV:0.2 MG/CUM RESP/DUST
Ingred Name:ZINC STEARATE
CAS:557-05-1
RTECS #:ZH5200000
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): >5000 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NON-HAZARDOUS. MATERIAL DOES NOT
NORMALLY IRRITATE SKIN, EYES, RESPIRATORY TRACT OR GI TRACT. VERY
LARGE AMOUNTS OF DUST MAY BE A MINOR IRRITANT TO THE RESPIRATORY
TRACT.
Explanation of Carcinogenicity:CARBON BLACK IS A SUSPECTED HUMAN
CARCINOGEN BY ACGIH.
Effects of Overexposure:INHALATION: COUGHING, WHEEZING, SHORTNESS OF
BREATH. EYES: REDNESS, TEARING, DISCOMFORT. SKIN: REDNESS, ITCHING.
Medical Cond Aggravated by Exposure:NONE WHEN MATERIAL USED AS
DESCRIBED BY PRODUCT LITERATURE.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE PERSON TO FRESH AIR. GIVE ARTIFICIAL
RESPIRATION OR OXYGEN IF NEEDED. EYES: FLUSH WITH LOTS OF WATER FOR
15 MINUTES. SEE DOCTOR. SKIN: WASH WITH SOAP AND WATER. INGESTED:
IF CONSCIO US, DILUTE BY DRINKING SEVERAL GLASSES OF WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, FOAM, DRY CHEMICAL OR CARBON DIOXIDE
Fire Fighting Procedures:AVOID INHALATION OF SMOKE. WEAR PROTECTIVE
CLOTHING AND SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:TONER IS A COMBUSTIBLE POWDER. WHEN
DISPERSED IN AIR, IT FORMS EXPLOSIVE MIXTURES.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP OR VACUUM AND PLACE IN A CONTAINER
FOR LATER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PROLONGED INHALATION OF
EXCESSIVE DUST.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED WHEN USED AS INTENDED, BUT MAY BE
REQUIRED FOR OTHER THAN NORMAL CUSTOMER USE IN BULK PROCESSING
FACILITIES.
Ventilation:NONE NORMALLY REQUIRED.
Other Protective Equipment:NONE NORMALLY REQUIRED.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING.
Supplemental Safety and Health
SOFTENING RANGE: 185F - 212F. TOTAL ITEM RECORD (TIR) SAYS PART NUMBER
IS 6R149; XEROX REPRESENTATIVE SAYS THEY DO NOT HAVE AND NEVER HAD
SUCH A NUMBER AND THAT THEIR PART NUMBER IS 6R139. MSDS GIVEN HMIS
WAS FOR 6R139.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:2
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER WITH FAINT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION MAY BE TOXIC.
==================== Disposal Considerations ====================
Waste Disposal Methods:WHEN DISPOSED THIS MATERIAL IS NOT A HAZARDOUS
WASTE ACCORDING TO 40 CFR 261. HOWEVER; STATE AND LOCAL
REQUIREMENTS MAY BE MORE RESTRICTIVE. CONSULTATION WITH STAE AND
LOCAL OFFICIALS IS ADVISED. INCI NERATE ONLY IN A CLOSED CONTAINER.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:HP 600 SPARKLE KLEEN
CAGE:HAMPT
CAGE:HAMPT
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: <10%
Other REC Limits:400 PPM
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:2-BUTOXYETHANOL
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: <5%
Other REC Limits:25 PPM (SKIN)
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
Ingred Name:TRITON X-100, OCTYLPHENOXYPOLYETHOXYETHANOL
CAS:9036-19-5
RTECS #:RI0525000
Fraction by Wt: <1%
Ingred Name:AMMONIUM HYDROXIDE(SARA III)
CAS:1336-21-6
RTECS #:BQ9625000
Fraction by Wt: <1%
Other REC Limits:25 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: <5%
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9192
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: <5%
Other REC Limits:1000 PPM
OSHA PEL:1800 MG/CUM
ACGIH TLV:1000 PPM
Ingred Name:WATER, H2O
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: <80%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: IRRITATION. INGESTION:
NAUSEA.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN/EYES: IRRITATION. INGESTION: NAUSEA.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/WATER. INGESTION: OBTAIN MEDICAL ATTENTION
IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE CONVENTIONAL METHODS OF EXTINGUISHING.
Fire Fighting Procedures:KEEP COOL W/WATER FOG.
Unusual Fire/Explosion Hazard:WHEN HEATED, AEROSOL CANS WILL RUPTURE &
MAY BECOME AIRBORNE. CONTAINERS MAY BURST WHEN PUNCTURED OR
INCINERATED.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP W/ABSORBENT MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. DON'T
EXPOSE TO TEMPERATURES >120F OR SUNLIGHT. DON'T SPRAY INTO OPEN
FLAME.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNLESS ABNORMAL AMOUNTS ARE USED IN
CONFINED AREAS.
Ventilation:NOT REQUIRED UNDER NORMAL USE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:205F
Vapor Density:>AIR
Spec Gravity:<1
Evaporation Rate & Reference:SLOWER THAN BU AC
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR WATER, WHITE LIQUID W/SOLVENT ODOR.
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, OPEN FLAME, HIGH TEMPERATURES >120F,
& SUNLIGHT
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. DON'T PUNCTURE OR INCINERATE CONTAINER.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:142L,1 SHOT LETTERING ENAMEL
CAGE:13294
CAGE:13294
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC, HIGH FLASH
AROMATIC NAPHTHA
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 1-5%
OSHA PEL:100 PPM
Ingred Name:1,3,5,-TRIMETHYLBENZENE
CAS:108-67-8
RTECS #:OX6825000
Fraction by Wt: 0.1-1%
OSHA PEL:25 PPM
ACGIH TLV:25 PPM
Ingred Name:MINERAL SPIRITS
Fraction by Wt: 20-30%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:1,2,4-TRIMETHYLBENZENE
CAS:95-63-6
RTECS #:DC3325000
Fraction by Wt: 0.1-1%
OSHA PEL:25 PPM
ACGIH TLV:25 PPM
Ingred Name:LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA, LACOLENE*92/3*
CAS:64742-89-8
Fraction by Wt: 1-5%
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:FATTY ACIDS C8-10, OXYBIS
(2,1-ETHANEDIYLOXY-2,1-ETHANEDIYL)ESTERS *92-3*
CAS:68037-38-7
Fraction by Wt: 0.1-1%
Ingred Name:CHROMATES
Fraction by Wt: 1-5%
OSHA PEL:0.1 MG/CUM
ACGIH TLV:0.05 MG/CUM
Ingred Name:COPPER COMPOUND
Fraction by Wt: 1-5%
Ingred Name:LEAD, INORGANIC LEAD (SUSPECTED HUMAN CARCINOGEN BY IARC,
NTP & ACGIH)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 5-10%
OSHA PEL:0.05 MG/CUM
ACGIH TLV:0.15 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICA, MICA, MUSCOVITE
CAS:12001-26-2
RTECS #:VV8760000
Fraction by Wt: 0.1-1%
OSHA PEL:20 MPPCF
ACGIH TLV:3 MG/M3 RDUST; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY TRACT
IRRITATION/HEADACHE/NAUSEA/CNS DEPRESSION/FATIGUE/UNCONSCIOUS.
INGESTION: GASTROINTESTINAL DISTURBANCES INCLUDING
NAUSEA/VOMITING/ANOREXIA/CONSTIPATION. ASPIRATION MAY CA USE
CHEMICAL PNEUMONITIS WHICH MAY BE FATAL. EYE:
IRRITATION/RED/TEAR/BLURRED VISION. SKIN: IRRITATION/DRYNESS.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:EYE: CONJUNCTIVAL/CORNEAL INJURY. SKIN:
DERMATITIS/ULCERATION. INHALATION/INGESTION: KIDNEY/LIVER/SYSTEMIC
DAMAGE. AFFECT HIGHER BRAIN FUNCTIONS. LEAD POISONING/SEVERE DAMAGE
TO RED BLOOD CELL FORMATI ON. KIDNEY/NERVOUS SYSTEM/IMPAIRMENT
OFREPRODUCTIVE SYSTEMS, DAMAGE TO UNBORN FETUSES & LUNG CANCER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, RESTORE
BREATHING. EYES: FLUSH W/LARGE QUANTITIES OF WATER FOR 15 MINS.
SKIN: REMOVE EXCESS MATERIAL W/PAPER TOWELS OR RAGS. WASH W/MILD
SOAP & WATER . INGESTION: DON'T INDUCE VOMITING. ASPIRATION HAZARD.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:100F
Lower Limits:0.9%
Extinguishing Media:CO2, DRY CHEMICAL
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE. WATER SPRAY SHOULD
BE USED TO COOL CONTAINERS EXPOSED TO FIRE. DON'T ENTER THE FIRE
AREA W/OUT PROPER PROTECTIVE EQUIPMENT/SCBA.
Unusual Fire/Explosion Hazard:COMBUSTIBLE LIQUID.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL HEAT SOURCES, OPEN FLAMES, &
OTHER SOURCES OF IGNITION. ABSORB WITH SOLID ABSORBENT. SHOVEL INTO
CONTAINERS. IF LARGE QUANTITIES ARE SPILLED, PERSONAL PROTECTIVE
EQUIPMENT MAY BE REQUIRE D.
======================Handling and Storage ======================
Handling and Storage Precautions:SECURE CLOSURES/KEEP CONTAINERS
UPRIGHT TO PREVENT LEAKAGE. STORE IN COOL WELL VENTILATED AREA.
GROUND CONTAINERS WHEN POURING. USE NON-FERROUS TOOLS.
Other Precautions:AVOID FREE FALL OF LIQUID IN EXCESS OF FEW INCHES.
DON'T FLAME CUT/BRAZE/WELD W/OUT RESPIRATOR. PAINT MUST BE SHIPPED
IN METAL CONTAINERS/PACKED IN STRONG OUTSIDE CARTONS W/UN
NUMBER/MATERIAL DESCRIPT ION/FLASH POINT MARKED ON PACKAGE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ORGANIC VAPOR RESPIRATOR WITH PARTICULATE FILTER
APPROVED BY NIOSH. USE NIOSH/MSHA APPROVED MECHANICAL FILTER
RESPIRATOR DURING FLAME CUTTING/BRAZING/WELDING. MAINTAIN
ENGINEERING & ADMINISTRATIVE CON TROLS.
Ventilation:LOCAL EXHAUST: PREFERRED-PAINT SPRAY BOOTH, 150 FPM FACE
VELOCITY. MECHANICAL (GENERAL): ACCEPTABLE FOR SMALL VOLUMES.
Other Protective Equipment:NON-SPARKING SHOES IN AREAS WHERE EXPLOSION
HAZARDS EXIST.
Work Hygienic Practices:PRACTICE GOOD HOUSEKEEPING & HANDLING.
Supplemental Safety and Health
THE PHYSICAL DATA INFORMATION (EXCEPT PERCENT VOLATILE) IS FOR SOLVENT
PORTION ONLY.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:246-385F
Vapor Pres:2-15
Vapor Density:3.8-4.9
Spec Gravity:0.74-0.89
Evaporation Rate & Reference:(ETHER = 1): 9-70
Solubility in Water:INSOLUBLE
Appearance and Odor:WATER WHITE LIQUID & CHARACTERISTIC PETROLEUM ODOR.
Percent Volatiles by Volume:25-35%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:FIRE, FLAME, STATIC ELECTRICITY, HEAT OR
ELECTRICAL SPARK, EXTREME HEAT, & OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:CO, NITROGEN OXIDES, LEAD, CHROMIUM
FUME
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE AS PAINT WASTE IN ACCORDANCE WITH
FEDERAL, STATE, & LOCAL REGULATIONS. COMBUSTIBLE LIQUID.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:N-BUTANOL
CAGE:8G964
CAGE:0LWP6
CAGE:8G964
============= Composition/Information on Ingredients =============
Ingred Name:N-BUTYL ALCOHOL (SARA III)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: >99%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS 2500 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY CAUSE IRRITATION TO SKIN,
EYES, NASAL PASSAGES. MAY CAUSE CENTRAL NERVOUS SYSTEM DEPRESSION
IF VAPORS INHALED OR LIQUID SWALLOWED. CHRONIC: NONE SPECIFIED BY
MANUFACTURER.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:INHALATION: SNEEZING, WHEEZING, SHORTNESS OF
BREATH, DIZZINESS, HEADACHE, STUPOR. EYES: REDNESS, TEARING,
BLURRED VISION. SKIN: REDNESS, RASH, ITCHING. INGESTION: NAUSEA,
DIZZINESS, HEADACHE, STUPOR.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN OR EYE DISORDERS
MAY BE AGGRAVATED BY EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE PERSON TO FRESH AIR. RESUSCITATE IF
NEEDED. EYES: FLUSH WITH PLENTY OF WATER FOR 15 MINUTES. SEE DOCTOR
IMMEDIATELY. SKIN: REMOVE CONTAMINATED CLOTHING AND WASH SKIN WITH
LARGE AMOU NT OF WATER. IF IRRITATION PERSISTS; SEEA DOCTOR.
INGESTED: INDUCE VOMITING OF CONSCIOUS PERSON AFTER GIVING 1-2
GLASSES OF WATER. SEE DOCTOR IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:98.0F,36.7C
Lower Limits:1.4%
Upper Limits:11.2%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE GEAR. WATER SPRAY MAY BE USED TO COOL CONTAINERS.
Unusual Fire/Explosion Hazard:VAPOR IS HEAVIER THAN AIR AND MAY TRVEL
TO SOME DISTANT POINT, FIND AN IGNITION SOURCE AND FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. VENTILATE AREA.
CONTAIN SPILL. ABSORB WITH INERT MATERIAL. AVOID RUNOFF TO SEWERS
AND WATERWAYS. CALL NATIONAL RESPONSE CENTER IF GREATER THAN 5000
LB/DAY SPILL (800-424-88 02).
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, WELL VENTILATED AREA.
KEEP AWAY FROM IGNITION SOURCES. KEEP CONTAINERS CLOSED WHEN NOT IN
USE. USE ONLY DOT APPROVED CONTAINERS.
Other Precautions:PROPERLY BOND AND GROUND DURING TRANSFER OPERATIONS.
USE NON-SPARKING TOOLS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:BASED ON CONTAMINATION LEVEL USE NIOSH/MSHA
APPROVED RESPIRATOR WITH ORGANIC VAPOR CARTRIDGE OR AIR-SUPPLIED
RESPIRATOR.
Ventilation:USE LOCAL EXHAUST.
Other Protective Equipment:AT SPILLS USE IMPERVIOUS BODY COVERING AND
BOOTS. EYE WASH STATION & SAFETY SHOWER SHOULD BE AVAILABLE.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
AVOID BREATHING VAPOR. AVOID CONTACT WITH SKIN, EYES, AND CLOTHING.
DISCARD CONTAMINATED LEATHER CLOTHING.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:244F,118C
Vapor Pres:4.4 MM HG
Vapor Density:2.57
Spec Gravity:0.81
Evaporation Rate & Reference:0.45 (N-BUTYL ACETATE=1)
Solubility in Water:7.8
Appearance and Odor:CLEAR, COLORLESS LIQUID WITH ALCOHOL ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:IGNITION SOURCES SUCH AS HEAT, SPARKS,
OPEN FLAME
Hazardous Decomposition Products:OXIDES OF CARBON
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. MANUFACTURER SAYS: INCINERATE OR BIOLOGICAL
DEGRADATION AT APPROVED FACILITY. DEFINED AS A HAZARDOUS WASTE BY
RESOURCE CONSERVATION RECOVERY ACT (40CFR261).
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:G & H LINES -LEAD FREE ALUMIGRIP
CAGE:EO831
CAGE:90608
CAGE:EO831
============= Composition/Information on Ingredients =============
Ingred Name:CELLOSOLVE ACETATE (ETHYLENE GLYCOL ETHYL ETHER ACETATE),
2-ETHOXYETHYL ACETATE
CAS:111-15-9
RTECS #:KK8225000
Fraction by Wt: 16-27%
OSHA PEL:100 PPM
ACGIH TLV:5 PPM SKIN
Ingred Name:DIISOBUTYL KETONE
CAS:108-83-8
RTECS #:MJ5775000
Fraction by Wt: 2-4%
Other REC Limits:25 PPM
OSHA PEL:50 PPM
ACGIH TLV:145 MG/CUM
Ingred Name:PROPYLENEGLYCOL MONOMETHYL ETHER ACETATE,
1-METHOXY-2-PROPANOL ACETATE
CAS:108-65-6
RTECS #:AI8925000
Fraction by Wt: 5-21%
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *96-3*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 3-5%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOLATILE ORGANIC CONTENT: 475-592 GM/L
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: IRRITATION,
DERMATITIS. INHALATION: IRRITATION TO NASAL & RESPIRATORY,
ASPHYXIATION. INGESTION: HARMFUL. OVEREXPOSURE MAY CAUSE LUNG
DISEASES, IRRITATION TO MUCOUS MEMBRANES, C NS DEPRESSION,
HEMORRHAGES INTO VARIOUSVITAL ORGANS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, REDNESS, TEARING, BLURRED VISION,
DEFATTING, DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, HEADACHE,
UNCONSCIOUSNESS, CHEST TIGHTNESS, BURNING SENSATION, SORE THROAT,
ABDOMINAL PAIN, VOMITING, DIA RRHEA. OVEREXPOSURE: IRRITATION,
NARCOTIC EFFECTS, KIDNEY, LIVER & LUNG INJURY, CORNEAL EFFECTS.
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & WATER. EYES: WASH W/WATER FOR 15 MINS.
INGESTION: DON'T INDUCE VOMITING. ASPIRATION HAZARD. INHALATION:
REMOVE TO FRESH AIR. GIVE CPR IF NEEDED. OBTAIN MEDICAL ATTENTION
IN ALL CAS ES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:82F
Lower Limits:1.1
Upper Limits:7
Extinguishing Media:DRY CHEMICAL/FOAM.
Fire Fighting Procedures:WEAR SCBA W/FULL FACEPIECE OPERATED IN
PRESSURE-DEMAND/POSITIVE PRESSURE MODE. CLOSED CONTAINERS MAY
EXPLODE WHEN EXPOSED TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:KEEP FROM HEAT & OTHER IGNITION SOURCES.
VAPORS MAY IGNITE EXPLOSIVELY, SPREAD LONG DISTANCES & BEYOND
CLOSED DOORS. MAINTAIN A CONTINOUS FLOW OF FRESH AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: ABSORB ON INERT MATERIAL & TRANSFER TO
HOOD. LARGE: ELIMINATE IGNITION SOURCES. STOP SOURCE. CONTAIN &
PUMP TO SALVAGE TANK. REMAINING LIQUID MAY BE ABSORBED W/INERT
MATERIAL & SHOVELED INTO CO NTAINERS W/NON-SPARKING TOOLS. (SEE
SUPP)
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CLOSURE TIGHT & UPRIGHT. KEEP
CONTAINER CLOSED WHEN NOT IN USE. DON'T STORE >120F/TRANSFER TO
BOTTLES/UNLABELED CONTAINERS.
Other Precautions:CONTAINERS MAY BE HAZARDOUS WHEN EMPTIED, THEY MAY
CONTAIN PRODUCT RESIDUES. PRODUCT MUST BE BLENDED W/OTHER PRODUCTS
PRIOR TO USE. READ WARNINGS & LABELS. DON'T GET IN EYES, ON
SKIN/CLOTHING, DON'T B REATHE VAPORS. FOR INDUSTRIAL USE ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE, PROPERLY FITTED RESPIRATOR
(NIOSH/MSHA APPROVED), DURING & AFTER APPLICATION UNLESS AIR
MONITORING DEMONSTRATES VAPOR, MIST & PARTICULATE LEVELS ARE BELOW
APPLICABLE LIMITS.
Ventilation:GENERAL/LOCAL EXHAUST VENTILATION TO MAINTAIN EXPOSURE
BELOW TLVS.
Other Protective Equipment:SOLVENT IMPERMEABLE CLOTHING & BOOTS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
MATERIALS TO AVOID CONT'D: NITRIC ACID. SPILLS CONT'D: PREVEN RUNOFF TO
SEWER/OTHER BODIES OF WATER. DON'T INCINERATE CLOSED CONTAINERS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:278-343F
Vapor Density:>1
Spec Gravity:1.05-1.37
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:LIQUID W/SOLVENT ODOR.
Percent Volatiles by Volume:50-63
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS, POTASSIUM-TERT-BUTOXIDE, PERMANGENATE, CHLOROFORM,
CHLOROSULFONIC ACID, HYDROGEN PEROXIDE (SUPP)
Stability Condition to Avoid:HEAT, SPARKS, FLAME & OTHER IGNITION
SOURCES, ELECTRICAL EQUIPMENT, TEMP >120F.
Hazardous Decomposition Products:CO, CO2. HEATED: TOXIC FUMES
==================== Disposal Considerations ====================
Waste Disposal Methods:ALLOW VOLATILE PORTION TO EVAPORATE IN HOOD
BEING SURE TO ALLOW TIME FOR VAPORS TO COMPLETELY CLEAR HOOD DUCT
WORK. DISPOSE OF CONTAMINATED ABSORBENT, CONTAINER & UNUSED
CONTENTS IAW/FEDERAL, STATE & LOCAL REGULATIONS. FLAMMABLE LIQUID,
UN1263.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CRC 1205
CAGE:0THM1
CAGE:0THM1
============= Composition/Information on Ingredients =============
Ingred Name:PHOSPHORIC ACID (SARA III)
CAS:7664-38-2
RTECS #:TB6300000
Fraction by Wt: <45%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 MG/M3/3 STEL
ACGIH TLV:1 MG/M3/3 STEL; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Other REC Limits:NONE SPECIFIED
Ingred Name:ADDITIVES (PROPRIETARY)
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY CAUSE IRRITATION TO SKIN
AND EYES ON CONTACT. MAY IRRITATE RESPIRATORY TRACT IF MIST
INHALED. MAY CAUSE IRRITATION OF GI TRACT IF SWALLOWED.
Explanation of Carcinogenicity:NONE SPECIFIED BY MANUFACTURER.
Effects of Overexposure:INHALATION: COUGHING, WHEEZING, SHORTNESS OF
BREATH, TIGHTNESS IN CHEST. EYES: REDNESS, BLURRED VISION, TEARING,
DISCOMFORT. SKIN: REDNESS, ITCHING, DISCOMFORT. INGESTED: NAUSEA,
VOMITING, DIARRHEA.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE PERSON TO FRESH AIR. EYES: FLUSH WITH LOTS
OF WATER FOR 15 MINUTES WHILE HOLDING EYELIDS OPEN. SKIN: REMOVE
CONTAMINATED CLOTHES. WASH WITH SOAP AND WATER. INGESTED: DO NOT
INDUCE V OMITING. IF CONSCIOUS; GIVE MILK AND/ORWATER. GET
IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, DRY CHEMICAL, FOAM, CARBON DIOXIDE
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH THOROUGHLY WITH WATER OR NEUTRALIZE WITH
SODIUM CARBONATE.
Neutralizing Agent:SODIUM CARBONATE OR 20% SOLUTION OF SODIUM
BICARBONATE
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING. KEEP CONTAINER
CLOSED WHEN NOT IN USE.
Other Precautions:RECOMMENDED FOR INDUSTRIAL USE ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RECOMMEND USE NIOSH/MSHA APPROVED RESPIRATOR
WITH ACID MIST CARTRIDGE IF USED IN CONFINED AREA. IF RESPIRATOR
USED; A PROGRAM IN ACCORDANCE WITH 29 CFR 1910.134 MUST BE
IMPLEMENTED.
Ventilation:LOCAL EXHAUST IS RECOMMENDED.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER. PROTECTIVE
CLOTHING TO PREVENT REPEATED OR PROLONGED CONTACT.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
SAFETY/HEALTH: HMIS TECHNICIAN DISAGREES WITH MFR; CONTACT WITH A
SOLUTION OF A PH OF 1 WILL CAUSE CHEMICAL BURNS. BE VERY CAREFUL
WHEN HANDLING THIS MATERIAL.
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:300F,149C
Melt/Freeze Pt:M.P/F.P Text:-50F,-46C
Vapor Pres:14 MM@ 20C
Spec Gravity:1.0
pH:1
Evaporation Rate & Reference:SAME AS WATER
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALIES, STRONG OXIDIZING AGENTS, ZINC, LEATHER, NYLON FABRIC, COLORED
LAMINATES.
Stability Condition to Avoid:AVOID CONTACT WITH INCOMPATIBLE MATERIALS.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. MANUFACTURER: FLUSH TO SEWER. MATERIAL IS
SUBJECT TO TITLE 3 SARA AND 40 CFR PART 372.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:171 8592 KODAK INDUSTREX DEVELOPER REPLENISHER, WORK SOLN
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 85-90%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM SULFITE
CAS:10117-38-1
RTECS #:WT3530000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:HYDROQUINONE (SARA 302/313) (CERCLA)
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9495
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ACETIC ACID,POTASSIUM SALT/POTASSIUM ACETATE
CAS:127-08-2
RTECS #:AJ3325000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:GLUTARALDEHYDE-BIS-POTASSIUM BISULFITE
CAS:68310-08-7
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:EXPECTED TO BE A LOW HAZ FOR
RECOMMENDED HANDLING. EYES:CAUSES IRRITATION. SKIN:CAUSES
IRRITATION. MAY CAUSE ALLERGIC SKIN REACTION. INGEST:EXPECTED TO BE
A LOW INGESTION HAZARD.
Explanation of Carcinogenicity:PER MSDS:CARCINOGENICITY CLASSIFICATION
(COMPONENTS PRESENT @0.1% OR MORE):IARC/ACGIH/NTP/OSHA/CA PROP
65:NONE.
Effects of Overexposure:EYE IRRITATION. SKIN IRRITATION. ALLERGIC SKIN
REACTION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:IF SYMPTOMATIC MOVE TO FRESH AIR.SYMPTOMS PERSIST GET
MED ATTN. EYE:IMMED FLUSH W/PLENTY OF WATER FOR @LEAST 15MINS.GET
MED ATTN IMMED. SKIN:IMMED REMOVE CONTAMIN CLOTH/SHOES.WASH
W/SOAP/PLENTY OF WATER.GET MED ATTN. INGEST:DRINK 1-2GLASSES O
FWATER. SEEK MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:NONE,NON-COMBUST
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING. FIRE/EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSISTION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER W/LG AMTS OF WATER. OTHERWISE
ABSORB SPILL W/VERMICULITE OR OTHER INERT MATL. THEN PLACE IN CNTNR
FOR CHEM WASTE. CLEAN SURFACE THORO TO REMOVE RESIDUAL
CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID EYE/SKIN/CLOTH CONTACT.USE
W/ADEQUATE VENTI.KEEP CNTRN CLSD.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:USE GOOD GEN VENTI(TYP 10AIR CHANGES/HR).MATCH VENTI RATES
W/CONDITIONS.MAINTAIN AIRBORNE LEVELS BELOW RECOMMENDED (SUP)
Other Protective Equipment:IMPERV PROT CLOTH APPROPRIATE TO EXPO
RISK.EYEBATH,WASH FACI,SAF SHOWER.WASH CONTAMIN CLOTH BEF
REUSE.DESTROY/CLEAN SHOE
Work Hygienic Practices:ROUTINE NONALKALINE(ACID)TYP HANDCLEANER
AFT HNDLG.
Supplemental Safety and Health
VENTI:EXPO LIMITS W/PROCESS ENCLOSURE/LOC EXHA VENTIIT/OTHER ENGINEER
CNTRLS.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:18MM @20C
Vapor Density:0.6
Spec Gravity:1.082
pH:10.4
Solubility in Water:COMPLETE
Appearance and Odor:YELLOW-ORANGE LIQUID, SLIGHT ODOR.
Percent Volatiles by Volume:85-90
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE W/COMMON MATERIALS & CONTAMINANTS W/WHICH THE MATERIAL MAY
REASONABLY COME INTO CONTACT.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:HAZ COMBUST PROD:NONE
(NON-COMBUSTIBLE). HAZ DECOMP PROD:SULFUR DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE/TREATMENT/DISPOSAL MAY BE SUBJECT TO
LOCAL, STATE AND FEDERAL REGULATIONS. FLUSH TO SEWER W/LG AMTS OF
WATER. CONTAINS CHEM SUBJECT TO REPORTING REQMTS OF SEC 313 OR
TITLE III OF SARA & 40CF R PART 372:HYDROQUINONE.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:DICHLORODIFLUORO METHANE
CAGE:72527
CAGE:TO282
CAGE:72527
============= Composition/Information on Ingredients =============
Ingred Name:DICHLORODIFLUOROMETHANE (SARA III)
CAS:75-71-8
RTECS #:PA8200000
Fraction by Wt: 100%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN AND EYES: CONTACT WITH LIQUID CAN
CAUSE FROST BITE, INDICATED BY PALLOR OR REDNESS, LOSS OF SENSATION
AND SWELLING.INHALATION:ASPHYXIATION. THIS PRODUCT CAN CAUSE DEATH
OR SERIOUS INJURY IF NOT H ANDLED PROPERLY.
Explanation of Carcinogenicity:NONE OF THE CHEMICALS IN THIS PRODUCT IS
LISTED BT IARC, NTP OR OSHA AS A CARCINOGEN.
Effects of Overexposure:FROST BITE, PALLOR, REDNESS, NUMBNESS,
BREATHING DIFFICULTIES.
Medical Cond Aggravated by Exposure:NOT KNOWN.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. IF BREATHING HAS STOPPED GIVE
ARTFICIAL RESPIRATION AND PROVIDE OXYGEN. CALL PHYSICIAN. DO NOT
GIVE EPINEPHRINE. SKIN OR EYE CONTACT: IMMEDIATELY BATHE FROST BITE
AREA WITH LUKEWARM WATER. CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NONFLAMMABLE. FOR SURROUNDING FIRE USE WATER FOG,
CARBON DIOXIDE, FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:LIQUID AND GAS UNDER PRESSURE. HEAT OF
FIRE WILL PRODUCE HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE PERSONNEL. VENTILATE THE AREA AND
ALLOW TO DISSIPATE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE, TRANSPORT & STORE
CAREFULLY/SECURELY TO AVOID ACCIDENTAL KNOCKING OVER/SEVERE
PHYSICAL IMPACTS. DO NOT EXPOSE TO DIRECT HEAT OR OVERPRESSURIZE
Other Precautions:DO NOT PUNCTURE OR DROP CYLINDERS OR EXPOSE TO
EXCESSIVE HEAT. USE AUTHORIZED CONTAINERS ONLY. CYLINDERS UNDER
PRESSURE, HANLE WITH GREAT CARE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED FOR NORMAL USE. FOR UNSUAL
SITUATIONS, WEAR SUPPLIED-AIR RESPIRATOR OR SELF-CONTAINED NIOSH
APPROVED BREATHING APPARATUS.
Ventilation:GENERAL
Other Protective Equipment:SAFETY SHOES ARE RECOMMENDED WHEN HANDLING
CYLINDERS.
Work Hygienic Practices:FOLLOW OSHA REGULATIONS FOR HANDLING CYLINDERS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:G3
Boiling Pt:B.P. Text:-22F,-30C
Melt/Freeze Pt:M.P/F.P Text:-252F,-158C
Vapor Pres:4700 MMHG
Vapor Density:4.3
Spec Gravity:[email protected]
Evaporation Rate & Reference:>ETHER (GAS)
Solubility in Water:0.008
Appearance and Odor:COLORLESS LIQUIFIED GAS WITH FAINT ETHEREAL ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
POWDERED FORMS OF ALUMINUM, MAGNESIUM AND ZINC. ACTIVE METALS SUCH AS
SODIUM, POTASSIUM AND CALCIUM.
Stability Condition to Avoid:HIGH HEAT, TEMPERATURES ABOVE 550C,
LIGHTED CIGAETTES, HOT SPOTS, WELDING.
Hazardous Decomposition Products:HALOGENS, HALOGEN ACIDS, AND POSSIBLY
CARBONYL HALIDES, SUCH AS PHOSGENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH LOCAL
AND FEDERAL REGULATIONS. OR RETURN TO SUPPLIER FOR RECLAMATION.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:MICORESTER WAX, MICEST WAX
Preparer's Name:WILLIAM J SIEFERT
CAGE:MICRC
CAGE:0ZJ32
CAGE:MICRC
============= Composition/Information on Ingredients =============
Ingred Name:STRYENE; (WAX IN STYRENE)
CAS:100-42-5
RTECS #:WL3675000
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SUPDAT: LABELING, PACKAGING AND RECORDKEEPING STANDARDS.
RTECS #:9999999ZZ
Ingred Name:RESP PROT: IS LIMITED. USE A NIOSH APPRVD POSITIVE PRESSURE
AIR SUPPLIED RESPIRATOR IF THERE IS ANY POTENTIAL (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3: FOR UNCONTROLLED RELEASE, EXPOSURE LEVELS ARE NOT
KNOWN/ANY OTHER CIRCUMSTANCES WHERE NIOSH APPRVD AIR (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: PURIFYING RESPIRATORS MAY NOT PROVIDE ADEQUATE
VENTILATION. WEAR NIOSH APPRVD (OR EQUIVALENT) FULL- (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: FACEPIECE AIRLINE RESPIRATOR IN THE POSITIVE
PRESSURE MODE WITH EMERGENCY ESCAPE PROVISIONS.
RTECS #:9999999ZZ
Ingred Name:EYE PROT: & FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: HEATED MATERIAL. AVOID CONTACT W/EYES, SKIN,
AND CLOTHING.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE CONT: LIQUID, AEROSOLS &
VAPS OF THIS PROD ARE IRRITATING & CAN CAUSE PAIN, TEARING,
REDDENING & SWELL ACCOMPANIED BY STINGING SENSATION AND/OR FEELING
LIKE THAT OF FINE DUST IN EYES. SKIN CONT: PRLNGD/RPTD CONT CAN
RSLT IN DEFAT & DRYING OF SKIN WHICH MAY RSLT IN SKIN IRRIT & DERM
(RASH). (EFTS OF OVEREXP)
Explanation of Carcinogenicity:STYRENE: IARC MONO, VOL 60, PG 233,
1994: GROUP 2B.
Effects of Overexposure:HLTH HAZ: INHAL: HDCH, DIZZ, NAUS, DECREASED
BLOOD PRESS, CHANGES IN HEART RATE & CYANOSIS MAY RSLT FROM OVEREXP
TO VAP/SKIN EXPOS. PRLNGD INHAL MAY BE HARMFUL. INGEST: IRRITATING
TO MOUTH, THROAT & S TOM. CHRONIC: SUSPECT CANCER HAZARD - RISK OF
CANCER DEPENDS ON DURATION & LEVEL OF EXPOSURE. OVEREXP MAY CAUSE
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE CONT: IMMED FLUSH W/PLENTY OF WATER FOR AT LST 15 MINS.
GET MED ATTN, IF IRRIT PERSISTS. SKIN CONT: WASH W/SOAP & WATER.
GET MED ATTN IF IRRIT DEVELOPS/PERSISTS. INHAL: REMOVE TO FRESH
AIR. IF NOT BRTHG, GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE OXYG.
GET IMMED MED ATTN. INGEST: DO NOT INDUCE VOMIT. GIVE VICTIM GLASS
OF WATER OR MILK. CALL PHYS/POIS CTL CTR IMMED. NEVER GIVE ANYTHING
(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:89.0F,31.7C
Extinguishing Media:ALCOHOL FOAM, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . CONTAINERS CAN BUILD UP PRESS IF EXPOSED TO HEAT
(FIRE).
Unusual Fire/Explosion Hazard:FLAMMABLE LIQUID. CAN RELEASE VAPORS THAT
FORM EXPLOSIVE MIXTURES AT TEMPERATURES AT OR ABOVE THE FLASHPOINT.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SPILL WITH INERT MATERIAL (E.G. DRY
SAND OR EARTH), THEN PLACE IN A CHEMICAL WASTE CONTAINER.
ECOLOGICAL INFO: DO NOT ALLOW MATERIAL TO ENTER SEWERS, CONTACT
SOIL OR ENTER ANY BODY OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & FLAME.
KEEP CNTNR CLSD WHEN NOT IN USE. USE ONLY IN WELL VENTILATED AREA.
AVOID PRLNGD/RPTD CONT W/SKIN. AVOID BRTHG VAP
Other Precautions:FOLLOW ALL MSDS/LBL PREC EVEN AFTER CNTNR IS EMPTIED
BECAUSE THEY MAY RETAIN PROD RESIDUES. GROUND & BOND CNTNRS WHEN
TRANSFERRING MATL. USE SPK-PROOF TOOLS & EXPLO PROOF EQUIP. AVOID
PRLNGD/RPTD CONT W/SKIN. AVOID BRTHG VAPS FROM (ING 8)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPRVD AIR PURIFYING RESPIRATOR W/ORGANIC
VAPOR CARTRIDGE/CANISTER MAY BE PERMISSIBLE UNDER CERTAIN
CIRCUMSTANCES WHERE AIRBORNE CONCS ARE EXPECTED TO EXCEED EXPOSURE
LIMITS. PROT PROVIDED BY NI OSH APPRVD AIR PURIFYING RESPS (ING 3)
Ventilation:LOCAL EXHST VENT MAY BE NECESSARY TO CONTROL ANY AIR
CONTAMINANTS TO WITHIN THEIR TLVS DURING USE OF THIS PRODUCT.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
CHEMICAL SUIT, RUBBER BOOTS.
Work Hygienic Practices:WASH HANDS BEFORE EATING. REMOVE CONTAMD CLTHG
& WASH BEFORE REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
HAZ DECOMP PROD: CARBON DIOXIDE & CARBON MONOXIDE. EFTS OF OVEREXP:
NERV SYS DMG. OVEREXP MAY CAUSE LUNG DMG. OVEREXP MAY CAUSE KIDNEY
DMG. MAY CAUSE LIVER DISORDER (E.G., EDEMA, PROTEINURIA) & DMG. F
IRST AID PROC: BY MOUTH TO UNCON PERSON. WASTE DISP METH: DISP OF
THIS MATL/ITS CNTNR REQS COMPLIANCE W/APPLIC (ING 2)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>293F,>145C
Vapor Density:HVR/AIR
Spec Gravity:0.9126
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Solubility in Water:NIL
Appearance and Odor:CLOUDY LIQUID. STYRENE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE WITH AMINES, ANHYDRIDES, ACIDS AND OXIDIZERS.
Stability Condition to Avoid:AVOID CONTACT WITH AMINES, ANHYDRIDES,
ACIDS AND OXIDIZERS. AVOID HEAT, FLAME AND SOURCES OF IGNITION.
Hazardous Decomposition Products:HAZ DECOMP IS UNLIKELY EXCEPT IN EVENT
OF FIRE. IN EVENT OF OVERHEATING/INCOMPLETE COMBUST, OXIDES OF
NITROGEN, (SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISP MUST BE I/A/W FED, STATE & LOC REGS . THIS
MATL HAS BEEN TESTED & FOUND TO HAVE FLASH POINT <40F. IF
DISCARDED, THIS MATL & CNTNRS SHOULD BE TREATED AS HAZ WASTE BASED
ON CHARACT OF IGNITAB ILITY AS DEFINED UNDER FED RCRA REGS.
(SUPDAT)
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:06 264F2K SOVAPON TNK LNG GRAY, 06-0264F2K
CAGE:13418
CAGE:13418
============= Composition/Information on Ingredients =============
Ingred Name:EPOXY RESIN
CAS:25068-38-6
RTECS #:KC2100000
Fraction by Wt: 25%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:METHYL N-AMYL KETONE
CAS:110-43-0
RTECS #:MJ5075000
Fraction by Wt: 5%
OSHA PEL:100 PPM
ACGIH TLV:50 PPM
Ingred Name:BISPHENOL A EPOXY RESIN; (EPOXY RESIN)
CAS:25036-25-3
Fraction by Wt: 5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:FORMALDEHYDE (SARA 302/313) (CERCLA)
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: <0.1%
OSHA PEL:N/K
ACGIH TLV:0.3 PPM, C
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:METHYL AMYL ALCOHOL
CAS:108-11-2
RTECS #:SA7350000
Fraction by Wt: 5%
OSHA PEL:25 PPM, S
ACGIH TLV:25 PPM; 40 STEL, S
Ingred Name:2-PROPANOL, 1-PROPOXY-; (PROPYLENE GLYCOL MONO PROPYL
ETHER)
CAS:1569-01-3
RTECS #:UB9351000
Fraction by Wt: 5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ISOBUTYL ISOBUTYRATE
CAS:97-85-8
RTECS #:NQ5250000
Fraction by Wt: 5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUND, THEORETICAL: 2.32 LBS/GAL; 278
G/L
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:HNDLG/STOR PRECS: SUITABLE STORAGE SHOULD BE PROVIDED I/A/W
OSHA REGULATION 1910.106.
RTECS #:9999999ZZ
Ingred Name:EYE PROT: & FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 15%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (CRYSTALLINE SILICA)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:SOLVENT NAPHTHA, PETROLEUM, MEDIUM ALIPHATIC; (ALIPHATIC
PETROLEUM DISTILLATES)
CAS:64742-88-7
RTECS #:WF3450000
Fraction by Wt: 1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TALC
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 25%
OSHA PEL:20 MPPCF
ACGIH TLV:2 MG/M3 RDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: HARMFUL IF INHALED. MAY AFFECT
BRAIN, NERVOUS SYS OR RESP SYS CAUSING DIZZ, HDCH, NAUS OR RESP
IRRIT. OVEREXP TO INGREDS IN PROD MAY CAUSE NOSE & THROAT IRRIT,
EYE IRRIT, EYE BURNS, SKIN IRRIT, ALLERGIC SKIN RXN, RESP TRACT
IRRIT, DERM, CORNEAL INJURY/EYE DMG. CHRONIC: POSS SENSIT. CONTAINS
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ: IARC MONO,
VOL 68, 1997:GROUP 1. NTP 7TH ANNUAL REPORT ON CARCINS, 1994:ANTIC
TO BE CARCIN.
Effects of Overexposure:HLTH HAZ: FORMALDEHYDE WHICH IS CONSIDERED
POTNTL CARCIN BY OSHA. PRLNGD EXPOS TO RESPIRABLE CRYSTALLINE
QUARTZ (SILICA) MAY CAUSE DELAYED (CHRONIC) LUNG INJURY
(SILICOSIS). SUSPECT CANCER HAZ. CONTAI NS INGREDS WHICH MAY CAUSE
CANCER. RISKOF CANCER DEPENDS UPON DURATION & LEVEL OF EXPOS.
NOTICE: REPORTS HAVE (SUPDAT)
Medical Cond Aggravated by Exposure:ANY RESPIRATORY OR SKIN CONDITION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMEDIATELY WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES AND GET MEDICAL ATTENTION. SKIN: WASH THOROUGHLY WITH SOAP
AND WATER. REMOVE CONTAMINATED CLOTHING AND SHOES. WASH CLOTHING
BEFORE REUSE. DESTROY CONTAMINATED SHOES. INHAL: REMOVE TO FRESH
AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS
DIFFICULT, GIVE OXYGEN. GET MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:102F,39C
Lower Limits:1.00%
Upper Limits:17.00%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM AND/OR WATER
FOG.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . CONTAINERS EXPOSED TO FIRE SHOULD BE KEPT COOL WITH
WATER SPRAY.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. AVOID BREATHING OF VAPORS. USE
NIOSH APPROVED SCBA OR AIRMASK FOR LARGE SPILLS IN CONFINED AREA.
AVOID ALL PERSONAL CONTACT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPKS & OPEN
FLAME. KEEP CNTNR CLOSED WHEN NOT IN USE. DO NOT STORE ABOVE 120F.
BASED ON PROD FLASH POINT & VAPOR PRESS (ING 13)
Other Precautions:EMPTY CONTAINERS MAY CONTAIN PRODUCT RESIDUE,
INCLUDING FLAMMABLE OR EXPLOSIVE VAPORS. DO NOT CUT, PUNCTURE OR
WELD ON OR NEAR CONTAINER. ALL LABEL WARNINGS MUST BE OBSERVED
UNTIL THE CONTAINER HAS BE EN CLEANED OR RECONDITIONED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:UNLESS AIR MONITORING DEMONSTRATES VAP/MIST
LEVELS ABOVE APPLIC LIMS, NO RESP IS REQUIRED. IF RESP IS REQUIRED,
APPROP, PROPERLY FITTED, NIOSH APPRVD RESP SHOULD BE WORN DURING
APPLICATION. FOLLOW RES P MFRS DIRECTIONS FOR RESP USE.
Ventilation:REQUIRED FOR SPRAYING OR IN A CONFINED AREA. VENTILATION
EQUIPMENT SHOULD BE EXPLOSION PROOF.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
NEOPRENE OR PLASTIC APRON & PROTECTIVE CLTHG COVERING EXPOSED SKIN
AREAS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HLTH HAZ: ASSOC RPTD & PRLNGD OCCUP OVEREXP TO SOLVS W/PERM BRAIN &
NERVOUS SYS DMG. INTENTIONAL MISUSE BY DELIB CONC & INHALING
CONTENTS MAY BE HARMFUL/FATAL. POSS SKIN & RESP SENSITIZER.
CONTAINS IN GREDS WHICH MAY CAUSE LIVER DMG, KIDNEYDMG, CORNEAL
INJURY OR EYE DAMAGE, PULM EDEMA.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:269F,132C
Vapor Pres:5.0 @ 68F
Vapor Density:5.9
Spec Gravity:1.56
Evaporation Rate & Reference:0.5 (BUTYL ACETATE=1)
Solubility in Water:NO
Appearance and Odor:NORMAL FOR COATINGS PRODUCT
Percent Volatiles by Volume:32.82
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:SILICON DIOXIDE, CARBON
DIOXIDE/MONOXIDE, METAL OXIDES, SULFUR OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN CHEMICAL DISPOSAL AREA OR IN A MANNER
THAT COMPLIES WITH LOCAL, STATE AND FEDERAL REGULATIONS. DO NOT
INCINERATE CLOSED CONTAINERS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ZEP ASSIST, 0323
CAGE:0990Y
CAGE:27674
CAGE:0990Y
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Effects of Overexposure:IN LIGHT OF GOOD INDUSTRIAL HYGIENE, EXPOSURE
TO ANY CHEMICAL SHOULD BE KEPT TO A MINIMUM.
======================= First Aid Measures =======================
First Aid:SKIN:FLUSH CONTAMINATED SKIN W/PLENTY OF WTR,CONSULT A
PHYSICIAN IF IRRITATION DEVELOPS. EYES: IMMED FLUSH EYES W/PLENTY
WTR @ LEAST 15 MIN. OCCASIONALLY LIFT UPPER/LOWER LIDS. GET MEDICAL
ATTEN AT ON CE. INHALE: MOVE VICTIM TO FRESH AIR. IF IRRIT PERSISTS
GET MED ATTEN AT ONCE. INGEST: DO NOT INDUCE VOMITING. IF VICTIM IS
CONSCIOUS GIVE LOTS OF WATER TO DRINK. GET MEDICAL ATTENTION AT
ONCE.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NONE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:DIRECT WATER ONTO INTACT CONTAINERS TO
PREVENT BURSTING.
================== Accidental Release Measures ==================
Spill Release Procedures:OBSERVE SAFETY PRECAUTIONS IN SECT 4 & 9
DURING SPILL CLEAN UP. LARGE SPILLS ARE UNLIKELY DUE TO PACK. SPILL
MAY BE ABSORB ON INERT ABSORB MAT (EG.ZEP-O-ZORB),& PLACED IN A
SUITABLE CNTNR FOR DISPOSAL . WASH AREA CLEAN W/DETER SOLUTION &
RINSE WELL.
======================Handling and Storage ======================
Handling and Storage Precautions:*A CHEMICAL OR INDUSTRIAL WASTE
LANDFILL. CONSULT LOCAL, STATE & FEDERAL AGENCIES FOR PROPER
DISPOSAL METHOD IN AREA.
Other Precautions:DO NOT STORE AT TEMPERATURES ABOVE 120F. OR IN DIRECT
SUNLIGHT. DO NOT PUNCTURE OR INCINERATE CONTAINER. KEEP OUT OF
REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL MEASURES ARE REQUIRED.
Ventilation:NO SPECIAL MEASURES ARE REQUIRED.
Other Protective Equipment:*IS STRONGLY RECOMMENDED, ESP FOR PROLONGED
LENSES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:220F,104C
Spec Gravity:1.015
Evaporation Rate & Reference:1.0 (WATER=1)
Solubility in Water:COMPLETE
Appearance and Odor:A THIN, CLOUDY LIQUID HAVING A CITRUS FRAGANCE.
Percent Volatiles by Volume:62%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE, AND
OTHER UNIDENTIFIED ORGANIC COMPOUNDS.
Conditions to Avoid Polymerization:ANY SOURCE OF IGNITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:PRODUCT IS CONSUMED IN USE. DO NOT CRUSH,
PUNCTURE OR INCINERATE SPENT CONTAINERS. LARGE NUMBERS OF AEROSOL
CONTAINERS MAY REQUIRE HANDLING AS A HAZ WASTE, BUT MOST STATES
TOTAL HAZ WASTE QUANTITIES L ESS THAN 220 LBS PER MONTH MAY ALLOW
DISPOSAL IN *
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:FLIT-TRAK INSECT MONITORING LURES,3153-25
CAGE:02RG7
CAGE:02RG7
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS/SYNTHETIC INSECT PHEROMONES IN
RUBBER SEPTA OR POLYVIALS (0.1-200 MG)
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS NOT RELEVANT.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:NONE. ACUTE AND CHRONIC-
NONE. PHERONONES ARE NON-TOXIC BIOCHEMICAL COMPOUNDS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NONE
======================= First Aid Measures =======================
First Aid:NONE
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH INERT MATERIAL SUCH AS SAND. PLACE
IN TRASH COLLECTION.
Neutralizing Agent:NOT RELEVENT
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN.
Other Precautions:WASH HANDS AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED.
Ventilation:ADEQUATE
Other Protective Equipment:EYE WASH FOUNTAIN
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
THE INSECT ATTRACTANT LURES DO NOT CONTAIN INGREDIENTS IN ANY QUANTITY
TO BE HAZARDOUS.
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NOT RELEVANT
Appearance and Odor:CLEAR LIQUID CONTAINED IN RUBBER SEPTA OR POLYVIAL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:EXCESSIVE HEAT
==================== Disposal Considerations ====================
Waste Disposal Methods:NON-TOXIC WASTE. OBSERVE ALL LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SLS/RH15
CAGE:62607
CAGE:62607
============= Composition/Information on Ingredients =============
Ingred Name:PHOSPHOR POWDER (INCLUDES INGRED #2)
Fraction by Wt: <0.5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:YTTRIUM OXIDE (AS YTTRIUM)
CAS:1314-36-9
RTECS #:ZG3850000
Fraction by Wt: <0.5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:LEAD (SARA 313) (CERCLA)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: <0.05%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE 1910.1025
ACGIH TLV:0.15MG/M3 DUST; 9495
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
Fraction by Wt: <0.1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9495
Ingred Name:BISMUTH
CAS:7440-69-9
RTECS #:EB2600000
Fraction by Wt: <0.005%
Other REC Limits:NONE RECOMMENDED
Ingred Name:MERCURY (SARA 313) (CERCLA)
CAS:7439-97-6
RTECS #:OV4550000
Fraction by Wt: 0.005%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C, 0.1 MG/M3; Z-2
ACGIH TLV:S,0.025 MG/M3; A4;95
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:GLASS (LMAP ENVEOLPE)
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Health Hazards Acute and Chronic:N/A TO INTACT LAMP.LUMINESCENT MATLS
CONTAINED WITHIN GLASS TUBES.BREAKAGE OF TUBE MAY RESULT IN SOME
EXPO TO PHOSPHOR POWDER DUST,MERCURY,SMALL ATMS OF
TIN,LEAD,BISMUTH.NO ADVERSE AFFECTS ARE EXPECTE D FRM OCCASSIONAL
EXPO TO BROKEN LAMPS BUT AS MATTER OF GOOD PRACTICE
PROLONGED/FREQUENT EXPO SHOULD BE AVOIDED (SUPPLE)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:NORMAL FIRST AIR PROCEDURE FOR GLASS CUTS IF SUCH OCCUR
THROUGH LAMP BREAKAGE.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Unusual Fire/Explosion Hazard:UNDER EXTREME HEAT GLASS TUBE MIGHT MELT
OR CRACK.
================== Accidental Release Measures ==================
Spill Release Procedures:NORMAL PRECAUTIONS SHOULD BE TAKEN FOR
COLLECTION OF BROKEN GLASS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:FOR INDOOR/OUTDOOR USE WHERE NOT SUBJ
TO WEATHER.NOT FOR USE IN LIGHTING DEVICES CNTRLD BY
DIMMERS.RELIABLE OPERATION DOWN TO 0F(WINDCHILL NOT FACTOR)
Other Precautions:CUSTOMERS SHOULD REVIEW THEIR WASTE HANDLING
PRACTICES TO ASSRUE THAT THEY ARE PROPERLY DISPOSING OF WASTE
LAMPS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:APPROPRIATE DUST MASK SHOULD BE USED IF LARGE
VOLUMES OF LAMPS ARE BEING BROKEN FOR DISPOSAL.
Ventilation:AVOID INHALATION OF ANY AIRBORNE DUST.PROVIDE LOCAL EXHAUST
WHEN DISPOSING LARGE QUANTITIES OF LAMPS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:AS MATTER OF GOOD PRACTICE PROLONGED/FREQUENT
EXPO SHOULD BE AVOIDED THRU USE OF ADEQUATE VENTI DURING DISPO OF
LG AMTS.
Supplemental Safety and Health
HEALTH HAZ:THRU ADEQ VENTI DURING LG QUANT OF LAMP DISPO. DISPO:LAMPS
FRM ALL MFG EXHIBIT SAME PHENOMENA.NEMA WORKS CLOSELY W/EPA FOR
CLARIF/GUIDANCE.SM AMT PLACED IN ORDINARY TRASH NOT APPREC AFFECT
METHOD OF DISPO.SPENT LAMPS ADD TO OTHER REG WASTE/LG AMTS,DISPO
REG.
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:ARITCLE, ITEM IS A LIGHT BULB.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
THE GLASS WILL REACT WITH HYDROFLUORIC ACID.
==================== Disposal Considerations ====================
Waste Disposal Methods:UNDER TCLP PROMULGATED BY US EPA,TESTS OF
USED/SPECNT FLUORESCENT/INCANDESCENT/HIGH INTENSITY DISCHARGE LAMPS
INDICATE SOME TYP MAY BE CLASSIFIED AS CHARACTERI HAZ WASTE.NOTABLY
TCLP RESULTS FOR FLUOR ESCENT LAMPS VARY TREMENDOUSLY FRM LAB TO
LAB(SUP)
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:25 YEAR CAULK, 97139
CAGE:82464
CAGE:82464
============= Composition/Information on Ingredients =============
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (MINERAL SPIRITS).
BP:>300F,>149C. VP:<11. LEL:1%. UEL:6%.
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 2%
OSHA PEL:500 PPM (MFR)
ACGIH TLV:200 PPM (MFR)
Ingred Name:ETHYLENE GLYCOL (SARA 313) (CERCLA)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 2%
OSHA PEL:N/K
ACGIH TLV:50 PPM, VAPOR, C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DIZZINESS, ABDOMINAL DISCOMFORT,
CENTRAL NERVOUS SYSTEM DEPRESSION, HEADACHE, CONJUNCTIVITIS,
NAUSEA, MUCOUS MEMBRANE IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD . EYES:FLUSH
W/WATER FOR AT LEAST 15 MINUTES & CONTACT MD. INGEST:DO NOT INDUCE
VOMITING. ADMINISTER WATER, CONTACT MD.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:>200F,>93C
Lower Limits:SEE ING 1
Upper Limits:SEE ING 1
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL, WATER.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:IRRITATING OR TOXIC GASES & AEROSOLS MAY
BE PRODUCED DURING BURNING.
================== Accidental Release Measures ==================
Spill Release Procedures:SCRAPE INTO CONTAINERS & DISPOSE OF I/A/W
LOCAL, STATE & FEDERAL REGULATIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE NEAR HEAT, SOURCES,
SPARKS OR FLAMES. STORE BETWEEN 40 & 120F. DO NOT FREEZE.
Other Precautions:DO NOT INGEST. KEEP AWAY FROM CHILDREN. NOT FOR
UNDERWATER USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:ADEQUATE VENTILATION - MECHANICAL EXHAUST RECOMMENDED.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH SKIN & HANDS AFTER USE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:SEE ING 1
Vapor Pres:SEE ING 1
Vapor Density:HVR/AIR
Spec Gravity:1.6 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Solubility in Water:SOLUBLE
Appearance and Odor:WHITE OR PIGMENTED SEMI-SOLID W/SLIGHT ODOR.
Percent Volatiles by Volume:82
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF MATERIAL I/A/W LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ASBESTOS
Preparer's Name:ROBERT L PERKINS
CAGE:3A730
CAGE:3A730
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE;(CHRYSOTILE ASBESTOS)
CAS:12001-29-5
RTECS #:CI6478500
Fraction by Wt: >95%
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC
Ingred Name:MAGNETITE; (MAGNETITE FE*20*4)
CAS:1309-38-2
RTECS #:OM4800000
Fraction by Wt: 0.5-2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPP DATA: TO HAVING ASBESTOS EXPOSURES. EYE: USUALLY
REVERSIBLE ON REMOVAL FROM EXPOSURE. INGEST: SOME STUDIES(ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3: INDICTE THAT ASBESTOS OVEREXP IS IMPLICATED AS CAUSE
OF GI & LARYNGEAL CANCERS, BUT THE EVIDENCE IS (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: CONFLICTING; NO DOCUMENTED HUMAN EFFECTS.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:SURVEILLANCE PROGRAM MUST BE ESTAB FOR
ASBESTOS-EXPOSED PERS I/A/W/REQS OF OSHA 29CFR.1910.1001.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: SPILLED MATLS. USE WATER/OTHER DUST
SUPPRESSANTS WHERE SWEEPING IS UNAVOIDABLE. DO NOT STIR UP
DUST.(ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: CLEAN-UP PERS SHOULD WEAR APPROVED RESPS & PROT
CLTHG. WASTE & CONTAMD PROT CLTHG MUST BE PLACED IN DUST-(ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: TIGHT CONTAINERS AND BE PROPERLY LABELED FOR
DISPOSAL.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH:A HAZARDOUS MATL UNDER CWA 207(A) & HAS
REPORTABLE QTY OF ONE POUND. DEPOSIT WASTE CNTNRS IN (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: SECURED LANDFILL IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS.
RTECS #:9999999ZZ
Ingred Name:OTHER PROT:RESP PROT & PROT CLTHG AS REQD BY APPLIC REG,
USE VACCUM/WET CLEANING METHODS, DISP OF DUST, FRIABLE (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: WASTE MATLS & CONTAMD PROT EQUIP IN DUST-TIGHT
CONTAINERS.
RTECS #:9999999ZZ
Ingred Name:RESP PROT: EFFICIENCY FILTERS; UP TO 100 TIMES PEL -
POWERED AIR-PURIFYING RESP W/HIGH-EFFICIENCY FILTERS OR (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: SUPPLIED-AIR RESPIRATOR OPERATED IN CONTINUOUS FLOW
MODE.
RTECS #:9999999ZZ
Ingred Name:VENT: DISPERSION INTO ENVIRON. ISOLATE WORK AREA & POST
SIGNS WHERE ASBESTOS CONTAM MAY EXCEED PEL. HAND/POWER(ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: OPERATED TOOLS WHICH MAY RELEASE ASBESTOS IN EXCESS
OF PEL MUST BE EQUIPPED WITH LOCAL EXHAUST SYSTEMS.
RTECS #:9999999ZZ
& FOOT COVERINGS ARE REQD UNDER CFR 1910.1001.
RTECS #:9999999ZZ
Ingred Name:STOR/HDNG: DUST W/OUT PROVIDING PROPER ENCLOSURE/CONTROL
MEASURES. USE DUST SUPPRESSION CONTROL MEASURES AT ALL (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19: STAGES OF ASBESTOS HNDLG, USE & DISP.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: INHAL: ANY DUST(INCLUDING
ASBESTOS) WHICH IS INHALED IN SUBSTANTIAL AMOUNTS, MAY IRRIT RESP
TRACT. EXTREME EXPOS CAN OVERWHELM NORMAL RESP DEFENSE MECHANISMS &
RESULT IN TEMP DFCLTY IN BRTHG. S KIN: ASBESTOS SPLINTERS MAY
PENETRATE SKIN & CAUSE ASBESTOS "CORNS". EYE: MAY CAUSE IRRIT &
ABRASIONS.(EFTS OF OVEREXP)
Explanation of Carcinogenicity:ASBESTOS: IARC MONOGRAPHS, SUPP, VOL 7,
PG 106, 1987: GROUP 1. NTP 7TH ANNUAL REPORT ON CARCINS, 1994:
KNOWN(SUPDAT)
Effects of Overexposure:HLTH HAZ: CHRONIC: INHAL: OVEREXP TO ASBESTOS
HAS CAUSED DMG TO LUNGS(ASBESTOSIS), LUNG CANCER & MESOTHELIOMA OF
PLEURA & PERITONEUM. SYMPS WHICH ARE USUALLY NOT MANIFESTED UNTIL
15-20 YEARS AFTER EXP OS, INCL LABORED BRTHG, CHEST PAINS, WEAKNESS
& CHEST TIGHTNESS. PLEURAL THICKENING, PLAQUES & EFFUSION ARE
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. IF BRTHG IS DFCLT, O*2 MAY BE
ADMIN. IF BRTHG HAS STOPPED, ADMIN ARTF RESP. CALL MD. SKIN: REMOVE
ASBESTOS SLIVERS PROMPTLY. IF "ASBESTOS CORN" DEVELS, SURG REMOVAL
MAY BE REQD. EYE: IRRIGATE GENTLY W/WATER FOR AT LEAST 15 MINS.
REFER TO OPHTHALMOLOGIST TO RULE OUT POSS OF DMG TO CORNEA/EYEBALL
BY FIBERS. INGEST: CALL MD IMMMEDIATELY. NOTE TO MD: A MEDICAL(ING
6)
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING MATERIAL IN
FIRE SITUATION.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT. AVOID MEDIA & PROCS THAT CAUSE AIRBORNE DUST.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID BRTHG DUST. NOTIFY SAFETY PERS OF SPILL.
PERMIT ONLY TRAINED CLEAN-UP PERS IN SPILL AREA. USE WET
METHS/APPRVD VACUUM CLEANING SYS TO PICK UP SPILLED MATLS. USE
WATER/OTHER DUST SUPRESSANTS WHER E SWEEPING IS UNAVOIDABLE. DO NOT
STIR UP(ING 7)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE ASBESTOS IN CLSD
CNTNRS(DUST-TIGHT) IN CLEAN, DRY, SECURE AREA. PROTECT CNTNRS FROM
DMG. DO NOT OPEN CNTNRS IN MANNER THAT CAN RELEASE (ING 19)
Other Precautions:BRTHG ASBESTOS DUST CAN CAUSE LUNG DMG & CANCER. RISK
OF LUNG CANCER IS GREATLY INCREASED FOR SMOKERS. DO NOT CREATE/BRTH
DUST, DRY-SWEEP/USE AIR HOSE FOR CLEANING, TAKE PROT EQUIP/CLTHG
HOME. DO FOLL OW RECOM WORK PRACS, WEAR APPRVD(ING 12)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE ASBESTOS EXPOS IN EXCESS OF PEL IS ANTIC,
WEAR A NIOSH/MSHA APPRVD RESP, AS FOLLOWS: UP TO 10 TIMES THE PEL,
HALF-MASK AIR PURIFYING RESP W/HIGH-EFFICIENCY FILTERS; UP TO 50
TIMES PEL - FULL FAC EPIECE AIR-PURIFYING RESP W/HIGH(ING 14)
Ventilation:PROVIDE ADEQ EXHST VENT & CAPTURE FILTRATION TO REMOVE
ASBESTOS PARTICULATE FROM WORKPLACE & MINIMIZE ITS (ING 16)
Other Protective Equipment:ANSI APPRVD EMER EYE WASH & DELUGE SHOWER.
FOR CONCS IN EXCESS OF OSHA PEL, SPEC CLTHG, SUCH AS COVERALLS,(ING
18)
Work Hygienic Practices:FOLLOW GOOD HOUSEKEEPING PRACTICES TO PREVENT
ACCUMULATION OF ASBESTOS-CNTNG DUSTS. AVOID INHAL OF ASBESTOS.
Supplemental Safety and Health
EXPLAN OF CARCIN:TO BE CARCINOGENIC. OSHA: CFR VOL 29, PG 1910.1001,
1987: OSHA CANCER HAZARD. HUMAN: LUNG. EFTS OF OVEREXP:
NONDISABLING CNDTNS, SEEN SEPARATELY/TOGETHER, THAT HAVE BEEN ASSOC
W/PRLNG D ASBESTOS EXPOS. RISK OF LUNG CANCER IS GREATLY INCREASED
FOR THOSE WHO SMOKE CIGARETTES REG IN ADDTN(ING 3)
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:1112F,600C
Spec Gravity:2.45 (H*2O=1)
Solubility in Water:VERY SLIGHT SOLUBLE
Appearance and Odor:WHITE FIBROUS W/NO ODOR.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:BAGS, FRIABLE ASBESTOS, WASTE & SCRAP MATL
SHOULD BE DISP OF IN A MANNER WHICH WILL AVOID AIRBORNE CONCS OF
ASBESTOS, SUCH AS USE OF DUST-TIGHT TRASH BAGS/CNTNRS. SUCH CNTNRS
SHOULD BE LABELED I/A/W 4 0CFR61.20. ASBESTOS IS ALSO CLASSIFIED
AS(ING 10)
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:84-3680,AMMONIUM SOLUTION, HOUSEHOLD, LAB GRADE
Preparer's Name:NOT PROVIDED.
CAGE:59896
Contract Num:MDA414-99-P-6483
CAGE:59896
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIUM HYDROXIDE
CAS:1336-21-6
RTECS #:BQ9625000
= Wt:20.
Other REC Limits:NOT PROVIDED.
OSHA PEL:50 PPM (AS NH3)
ACGIH TLV:25 PPM (AS NH3)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) 350 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: RESPIRATORY AND
DIGESTIVE SYSTEMS. EMERGENCY OVERVIEW: IRRITANT. MAY CAUSE BURNS.
MAY BE HARMFUL IF SWALLOWED. POTENTIAL HEALTH EFFECTS: EYES: MAY
CAUSE IRRITATION. SKIN: MAY CAUSE IRRI TATION. INGESTION: MAY CAUSE
GASTROINTESTIONAL DISCOMFORT. INHALATION: MAY CAUSE IRRITATION TO
RESPIRATORY TRACT. CHRONIC - NOT CAUSING CANCER.
Explanation of Carcinogenicity:NOT LISTED AS CAUSING CANCER BY IARC,
NTP, OR OSHA.
Effects of Overexposure:IRRITANT. MAY CAUSE BURNS. EYES: MAY CAUSE
IRRITATION. SKIN: MAY CAUSE IRRITATION. INGESTION: MAY CAUSE
GASTROINTESTIONAL DISCOMFORT. INHALATION: MAY CAUSE IRRITATION TO
RESPIRATORY TRACT.
Medical Cond Aggravated by Exposure:RESPIRATORY CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES, RAISING AND
LOWERING EYELIDS OCCASIONALLY. GET MEDICAL ATTENTION IF IRRITATION
PERSISTS. SKIN: THOROUGHLY WASH EXPOSED AREA FOR AT LEAST 15
MINUTES. REM OVE CONTAMINATED CLOTHING. GET MEDICAL ATTENTION IF
IRRITATION PERSISTS. INGESTION: IF SWALLOWED, IF CONSCIOUS, GIVE
PLENTY OF WATER. IMMEDIATELY CALL A PHYSICIAN OR POISON CONTROL
CENTER. NEVER GIVEANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN IF BREATHING IS
DIFFICULT; GIVE ARTIFICIAL RESPIRATION IF BREATHING HAS STOPPED.
KEEP PERSON WARM AND QUIET, AN D GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:LIQUID NOT FLAMM
Autoignition Temp:=651.1C, 1204.F
Autoignition Temp Text:NH3
Lower Limits:16% NH3 GAS
Upper Limits:25% NH3 GAS
Extinguishing Media:DRY CHEMICAL, CO2 OR APPROPRIATE FOAM
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR FULL PROTECTIVE
EQUIPMENT AND NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:DANGEROUS FIRE HAZARD; EMITS IRRITATING
FUMES AND LIQUID CAN INFLICT BURNS.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA OF SPILL. ELIMINATE ALL SOURCES
OF IGNITION. REMOVE ALL NON-ESSENTIAL PERSONNEL FROM AREA. CLEAN-UP
PERSONNEL SHOULD WEAR PROPER PROTECTIVE EQUIPMENT AND CLOTHING.
ABSORB MATERIAL WITH SUITABLE ABSORBENT AND CONTAINERIZE FOR
DISPOSAL.
Neutralizing Agent:DILUTE ACID (HMIS).
======================Handling and Storage ======================
Handling and Storage Precautions:STORE TIGHTLY CLOSED IN A WELL
VENTILATED AREA AWAY FROM SOURCES OF IGNITION AND SEPARATE FROM
OXIDIZERS AND ACIDS.
Other Precautions:DO NOT BREATHE VAPOR.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH/MSHA CHEMICAL CARTRIDGE RESPIRATOR
SHOULD BE WORN IF PEL OR TLV IS EXCEEDED.
Ventilation:LOCAL:PREFERRED. MECHANICAL:ACCEPTABLE.
ALL TIMES.
Other Protective Equipment:LAB COAT, EYE WASH AND SAFETY SHOWER
Work Hygienic Practices:NOT PROVIDED.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:B1
NRC/State Lic Num:NOT RELEVANT.
Boiling Pt:B.P. Text:RELEASES NH3
Melt/Freeze Pt:=-77.C, -106.6F
Vapor Pres:755@ 26.7C(TOTAL)
Vapor Density:0.596
Spec Gravity:0.897
pH:NOT PROVIDED.
Viscosity:NOT PROVIDED.
Evaporation Rate & Reference:<1 (H2O=1)
Solubility in Water:MISCIBLE
Appearance and Odor:COLORLESS LIQUID WITH A DISTINCT, PUNGENT ODOR
Percent Volatiles by Volume:100
Corrosion Rate:NOT PROVIDED.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, OXIDIZERS, ACROLEIN, DIMETHYL SULFATE, HALOGENS, SILVER
COMPOUNDS, SODIUM HYDROXIDE, COPPER, IRON, CALCIUM.
Stability Condition to Avoid:HEATING PRODUCES TOXIC, IRRITATING AND
CORROSIVE AMMONIA GAS.
Hazardous Decomposition Products:NH3; NOX
=================== Toxicological Information===================
Toxicological Information:NH3: IHL - HMN LCL0: 5000 PPM/5M; ORAL-RAT
LD50: 350 MG/KG
===================== Ecological Information =====================
Ecological:EPA WASTE NUMBERS: D002.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE, AND LOCAL REGULATIONS. ALWAYS CONTACT A PERMITTED
WASTE DISPOSER (TSD) TO ASSURE COMPLIANCE. EPA WASTE NUMBERS: D002.
=================== MSDS Transport Information ===================
Transport Information:CONSUMER COMMODITY / ORM-D FOR 500 ML AND 4 L
BOTTLES.
===================== Regulatory Information =====================
SARA Title III Information:HAZARD CATEGORY FOR SARA SECTIONS 311/312
REPORTING: ACUTE. CERCLA SEC. 103, RQ LBS.: 1000.
Federal Regulatory Information:EPA TSCA STATUS: ON TSCA INVENTORY.
State Regulatory Information:NOT PROVIDED.
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ORGANIC PHOTOCONDUCTOR FOR MODEL 1220
CAGE:TO109
CAGE:TO109
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM CYLINDER
> Wt:97.
Ingred Name:BINDER RESIN
< Wt:1.
Ingred Name:PHOTOSENSITIVE MATERIAL
< Wt:1.
Ingred Name:PIGMENT
< Wt:1.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THE RESULT OF AMES TEST FOR COATED
LAYERS IS NEGATIVE.
Effects of Overexposure:NONE.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMEDIATELY . INHALATION: REMOVE TO FRESH
AIR. SUPPORT BREATHING (GIVE OXYGEN/ARTIFICIAL RESPIRATION) . EYES:
IMMEDIATELY FLUSH EYES WITH POTABLE WATER FOR AT LEAST 15 MINU TES.
SEEK ASSISTANCE FROM MD . SKIN: FLUSH WITH COPIOUS AMOUNTS OF
WATER. CALL MD .
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM OR WATER.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . THIS MATERIAL WILL BE SCORCHED IN THE CASE OF FIRE.
Unusual Fire/Explosion Hazard:THIS MATERIAL HAS NO UNUSUAL FIRE OR
EXPLOSION HAZARDS.
================== Accidental Release Measures ==================
Spill Release Procedures:NO SPECIAL PRECAUTION.
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL STORAGE REQUIREMENTS FOR
SAFETY REASONS.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NONE REQUIRED UNDER NORMAL USE.
Ventilation:LOCAL EXHAUST: NO. MECHANICAL (GENERAL): NO. SPECIAL: NO.
OTHER: NO.
Other Protective Equipment:NONE REQUIRED UNDER NORMAL USE.
Work Hygienic Practices:NONE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:2.7 (H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GREEN, ODORLESS AND SOLID CYLINDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:CO, CO*2 AND NO*X.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MATERIAL MAY BE DUMPED OR INCINERATED
UNDER CONDITION WHICH MEET ALL FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:DOT: NOT REGULATED.
===================== Regulatory Information =====================
State Regulatory Information:
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:COOLCUT
Preparer's Name:ANDY LECOUFFE
CAGE:JWALT
CAGE:JWALT
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM OXIDE, BAUXITE, ALUMINA, DIALUMINUM TRIOXIDE
*96-2*
CAS:1344-28-1
RTECS #:BD1200000
Fraction by Wt: 60-80%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM
Ingred Name:SILICON CARBIDE
CAS:409-21-2
RTECS #:VW0450000
Fraction by Wt: 1-5%
ACGIH TLV:10 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:UNCONTROLLED DUST CAN AFFECT EYES,
SKIN & RESPIRATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:UNCONTROLLED DUST CAN AFFECT EYES, SKIN &
RESPIRATION.
======================= First Aid Measures =======================
First Aid:SKIN: RINSE THOROUGHLY W/SOAP & WATER. EYES: RINSE THOROUGHLY
W/PLENTY OF WATER. DON'T REMOVE EMBEDDED OBJECTS. INHALATION:
REMOVE TO FRESH AIR. TREAT SCRAPES/CUTS BY CLEANSING WOUND. APPLY
STERILE DR ESSING. OBTAIN MEDICAL ATTENTION IN ALLCASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, CO2, CHEMICAL
============= Exposure Controls/Personal Protection =============
Ventilation:ADEQUATE
Other Protective Equipment:PROTECTIVE CLOTHING.
Work Hygienic Practices:FOLLOW SAFETY STANDARDS FOR GRINDING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:>1
Appearance and Odor:CHARACTERISTIC SOLID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:186 2176,EKTPRNT 2 BLEACH-FIX, PART B
Kit Part:Y
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 45-55%
Ingred Name:AMMONIUM FERRIC ETHLYENEDIAMINETETRAACETIC ACID
CAS:21265-50-9
Fraction by Wt: 40-45%
Ingred Name:AMMONIA (SARA III)
CAS:7664-41-7
RTECS #:BO0875000
Fraction by Wt: 6%
OSHA PEL:50 PPM
ACGIH TLV:25 PPM/35 STEL; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:ETHYLENEDIAMINE-TETRAACETIC ACID (EDTA) (SARA III)
CAS:60-00-4
RTECS #:AH4025000
Fraction by Wt: 1-5%
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS 0.5 - 5.0 G/KG
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: LOW HAZARD FOR USUAL
INDUSTRIAL HANDLING. EYES: NO SPECIFIC HAZARD KNOWN TO EASTMAN
KODAK COMPANY. HOWEVER, ANY MATERIAL THAT CONTACTS THE EYE MAY BE
IRRITATING. SKIN: LOW HAZARD FOR USUAL INDUSTRIAL HANDLING.
INGESTION: EXPECTED TO BE A LOW INGESTION HAZARD.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYE, SKIN & RESPIRATORY TRACT IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR 15 MINUTES
HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION. INGESTION: DO NOT
INDUCE VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GIVE 1-2
GLASSES OF WAT ER. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:NONE
Extinguishing Media:USE APPROPRIATE AGENT FOR SURROUNDING FIRE.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE UNPROTECTED PERSONS,PROVIDE
VENTILATION, SAFETY EQUIPMENTS IF NECESSARY.DIKE LARGE SPILL & PUMP
INTO COVERED CONTNRS;ABSORB SM SPILL W/ABSORBING MATL & PLACE IN
SAME CONTNR;MFR SUGGESTS FLUSH DOWN TO SEWER W/LG AMT OF H*2O IAW
EXISTING REGS.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM CONATACT WITH OXIDIZING
MATERIALS. AVOID CONTACT WITH METALS.
Other Precautions:AVOID PROLONGED AND REPEATED SKIN CONTACT WITH
PRODUCT. REMOVE & WASH CONTAMINATED CLOTHING. WASH HANDS AFTER USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:MECHANICAL (GENERAL) ROOM VENTILATION IS NORMALLY ADEQUATE.
Other Protective Equipment:NONE
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
IN 1980,KIT CAT #121 6407 WAS CHANGED TO 186 2176;KIT UNDER OLD CAT #
HAD 6 PARTS(SEE PNI A TO F);NEW KIT HAS 7 PARTS(SEE PNI G TO M);THE
CAT #186 5849 FOR EKTAPRINT 2 BLEACH-FIX,PART B WHEN STANDS AL ONE
BUT WHEN IN THE KIT THE CAT#186 2176 IS APPLIED TO BLEACH-FIX;MSDS
OF CAT #186 5849 USED FOR KITCAT #;KEY1:N1.(3422)
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.29
pH:7.0
Solubility in Water:COMPLETE
Appearance and Odor:OPAQUE; REDDISH-BROWN SOLUTION; SLIGHT AMMONIACAL
ODOR
Percent Volatiles by Volume:55
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
METALS; STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:COMBUSTION WILL PRODUCE CARBON
MONOXIDE & CARBON DIOXIDE. AMMONIA GAS AND OXIDES OF NITROGEN MAY
ALSO BE PRESENT.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED CONTAINERS PENDING
DISPOSAL.DISPOSE IN FULL COMPLIANCE W/FEDERAL,STATE & LOCAL
REGS;MFR RECOMMENDS TO FLUSH DOWN TO SEWER W COPIOUS AMT H*2O.STATE
& LOCAL EFFLUENT LAWS TAKE PRECEDENCE .
| 0 |
gloves_not_mandatory
|
=======================================================
NIIN: 00-235-5581
Product ID: LUBRICATING OIL,COLLOIDAL GRAPHITE
Cage: 03432
Box: 610104
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 03432
Box: 610104
=======================================================
Item Description Information
=======================================================
Item Manager: S9G
Item Name: LUBRICATING OIL,COLLOIDAL GRAPHITE
Specification Number: MIL-L-3572A
Type/Grade/Class: GRADE A
Unit of Issue: GL
UI Container Qty: 1
Type of Container: CAN
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: TLV:NOT DETERMINED ON MIXTURES.
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: PROLONGED OR REPEATED SKIN CONTACT MAY CAUSE MILD
IRRIT.CONTACT WITH EYES MAY CAUSE IRRIT.
Explanation Of Carcinogenicity: PER MSDS:CARCINOGEN:NTP/IARC:NA.
Signs And Symptions Of Overexposure: MILD SKIN IRRIT, EYE IRRIT.
First Aid: SKIN:WASH W/SOAP/WATER.CONTACT PHYSICIAN IF IRRIT DEVELOPS.EYE:FLUSH
W/COPIOUS AMTS OF WATER.SEE PHYSICIAN IF IRRIT DEVELOPS.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: RECOVER FREE LIQUID. ADD OIL ABSORBENT TO SPILL AREA.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: INCINERATE OR DISOSE OF AS FOR WSTE PETROLEUM OIL IAW
LOCAL, STATE AND FEDERAL REGULATIONS.KEEP OUT OF STREAMS & WATERWAYS.
Handling And Storage Precautions: KEEP CONTAINERS CLOSED & AWAY FROM HEAT
& OPEN FLAME.CAUSES BLACK STAINS WHICH ARE DIFFICULT TO REMOVE.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: COC
Flash Point Text: 315F,157C
Autoignition Temp Text: N/ESTA
Lower Limits: 1
Upper Limits: 6
Extinguishing Media: CARBON DIOXIDE, FOAM, DRY CHEMICAL, WATER SPRAY OR FOG.
Fire Fighting Procedures: USE AIR-SUPPLIED RESCUE EQPMT FOR ENCLOSED AREA.COOL
EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard: DO NOT STORE OR MIX WITH STRONG OXIDANTS.
=======================================================
Control Measures
=======================================================
Respiratory Protection: AIR-SUPPLIED EQPMT IF EXPOSED TO HOT FUMES.
Ventilation: LOCAL EXHAUST:TO CAPTURE OR REMOVE HOT FUMES.
Other Protective Equipment: OIL IMPERVIOUS APRON IF SPLASHING IS LIKELY FOR
PROTECTION OF PERSONAL CLOTHING.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT
GET ON SKIN OR IN EYES. DO NOT BREATHE VAPORS OR MISTS.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: V6
B.P. Text: N/DETERMINE
Vapor Pres: 0.01 @20C
Vapor Density: 11
Spec Gravity: 0.91
PH: NA
Evaporation Rate & Reference: 0.01, N-BUTYL ACETATE=1
Solubility in Water: IMMISCIBLE.
Appearance and Odor: BLACK LIQUID WITH PETROELUM OIL ODOR.
Percent Volatiles by Volume: NEGLIG
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: STRONG OXIDANTS (OXYGEN, CHLORINE).
Materials To Avoid: STRONG OXIDANTS (OXYGEN, CHLORINE).
Hazardous Decomposition Products: CARBON MONOXIDE IN THE EVENT OF INCOMPLETE
COMBUSTION.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 58790
Product ID: LUBRICATING OIL,COLLOIDAL GRAPHITE
Review Date: 05/08/1997
Net Unit Weight: 7.6 LBS
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: GL
Container QTY: 1
Type Of Container: CAN
Additional Data: PER MSDS:PROPER DOT SHIPPING NAME:NOT REGULATED;DOT HAZ
CLASSIFICATION:NOT REGULATED.
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: LUBRICATING OIL,COLLOIDAL GRAPHITE
Cage: 03432
Company Name: HURON INDUSTRIES INC
Street: 2301 16TH ST
PO Box: 610104
Zipcode: 48061-0104
Label Required IND: Y
Date Of Label Review: 05/08/1997
Status Code: C
MFG Label NO: NOT RELEVANT
Label Date: 05/08/1997
Year Procured: 1997
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: IRRITANT.EYE HAZ:IMPAIRED VISION,CONJUNCTIVITS,CORNEAL
DMG.CUTANEOUS HAZ:SKIN DMG,RASHES,IRRIT,DEFATTIN.PROLONGED OR REPEATED SKIN
CONTACT MAY CAUSE MILD IRRIT.CONTACT WITH EYES MAY CAUSE IRRIT. KEEP
CONTAINERS CLOSED & AWAY FROM HEAT & OPEN FLAME.CAUSES BLACK STAINS
WHICH ARE DIFFICULT TO REMOVE. FIRST AID: SKIN:WASH W/SOAP/WATER.CONTACT
PHYSICIAN IF IRRIT DEVELOPS.EYE:FLUSH W/COPIOUS AMTS OF WAT ER.SEE PHYSICIAN
IF IRRIT DEVELOPS. TARGET ORGANS:EYE/SKIN.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:2000 RT FIXER/REPLENISHER
CAGE:IO762
CAGE:IO762
CAGE:64145
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 40-45%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:THIOSULFURIC ACID, DIAMMONIUM SALT; (AMMONIUM THIOSULFATE)
CAS:7783-18-8
RTECS #:XN6465000
Fraction by Wt: 40-45%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM ACETATE
CAS:127-09-3
RTECS #:AJ4300010
Fraction by Wt: 3-6%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM SULFITE(2:1)
CAS:7757-83-7
RTECS #:WE2150000
Fraction by Wt: 1-3%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM BISULFITE
CAS:7631-90-5
RTECS #:VZ2000000
Fraction by Wt: 1-3%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: MAY CAUSE IRRITATION.
SKIN: MAY CAUSE IRRITATION. INHAL: LOW HAZARD UNDER TYPICAL USE
CONDITIONS. INGEST: MAY IRRITATE GI TRACT. CHRONIC: NOT KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. GET MED ATTN.
SKIN: WASH THORO WITH SOAP AND WATER. INGEST: IF CONSCIOUS, DRINK
3-4 GLASSES OF WATER AND DO NOT INDUCE VOMIT. GET MED ATTN. INHAL:
REMOV E TO FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Extinguishing Media:USE MEDIA APPROPRIATE FOR PRIMARY SOURCE OF FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:FIRE AND EXCESSIVE HEAT MAY PRODUCE
HAZARD DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:DILUTE W/WATER AND FLUSH TO SEWER, IF
PERMITTED. DISCHARGE, TREATMENT OR DISPOSAL MAY BE REGULATED
FEDERAL, STATE OR LOCAL LAWS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:TO USE PRODUCT SAFELY, READ MSDS, LBLS
AND INSTRUCTIONS AND CARRY OUT APPROPRIATE PRECAUTIONS. STORE IN A
COOL DRY AREA AWAY FROM STRONG ACIDS/ALKALIS
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:MECH-GOOD GEN VENT. 10-12 ROOM VOL CHANGERS PER HR.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:<32F,<0C
Vapor Pres:AS WATER
Vapor Density:AS WATER
Spec Gravity:1.333
pH:5.1
Evaporation Rate & Reference:SLOW
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS TO LIGHT YELLOW-VINEGAR ODOR
Percent Volatiles by Volume:45(WT)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG MINERAL ACIDS/STRONG ALKALI.
Hazardous Decomposition Products:OXIDES OF NITROGEN, SULFUR OR AMMONIA
GAS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DILUTE W/WATER. FLUSH TO SEWER WITH PLENTY OF
WATER PERMITTED BY APPLICABLE DISPOSAL REGULATIONS. MAY REQUIRE
DISPOSAL BY AN APPROVED CONTRACTOR.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:DYMEL 12
Preparer's Name:K. P. BROWN
CAGE:FO671
CAGE:73925
CAGE:FO671
============= Composition/Information on Ingredients =============
Ingred Name:DICHLORODIFLUOROMETHANE, FREON 12
CAS:75-71-8
RTECS #:PA8275000
Fraction by Wt: 100%
Other REC Limits:1000 PPM
OSHA PEL:4950 MG/CUM
ACGIH TLV:4950 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 1000 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION/INGESTION: EXCLUSION OF
OXYGEN/ANAESTHETIC
EFFECTS/DIZZINESS/CONFUSION/INCOORDINATION/UNCONSCIOUSNESS/TEMPORAR
Y ALTERATION OF HEART'S ELECTRICAL ACTIVITY W/IRREGULAR
PULSE/PALPITATIONS/INAD EQUATE CIRCULATION/TEMPORARY NERVOUS SYSTEM
DEPRESSION.SKIN/EYES: MILD IRRITATION/ FROSTBITE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: HARMFUL, HEART IRREGULARITIES,
UNCONSCIOUSNESS, DEATH.
Medical Cond Aggravated by Exposure:DISEASES OF CENTRAL NERVOUS
SYSTEM/CARDIOVASCULAR SYSTEM.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRATION. GIVE OXYGEN. SKIN: FLUSH W/WATER. TREAT FOR
FROSTBITE IF NECESSARY. EYES: FLUSH W/PLENTY OF WATER. OBTAIN
MEDICAL ATTENT ION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:NONFLAMMABLE
Extinguishing Media:AS APPROPRIATE FOR COMBUSTIBLES IN AREA.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS IF
CONTAINERS RUPTURE & CONTENTS ARE RELEASED UNDER FIRE CONDITIONS.
Unusual Fire/Explosion Hazard:CONTAINERS EQUIPED W/PRESSURE RELIEF
DEVICES MAY RUPTURE UNDER FIRE CONDITIONS. DECOMPOSITION MAY OCCUR.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE OPEN FLAME. VENTILATE AREA. DON'T FLUSH
INTO SEWERS. COLLECT LIQUID ON ABSORBENT MATERIAL. DIKE SPILL.
COMPLY W/FEDERAL, STATE, & LOCAL REGULATIONS ON REPORTING RELEASES.
FOR LARGE SPILL, WEAR SELF-CONTAINED BREATHING APPARATUS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLEAN, DRY AREA. DON'T HEAT
>125F. AVOID INHALATION OF VAPOR. AVOID LIQUID CONTACT W/SKIN &
EYES. USE ONLY IN WELL VENTILATED AREAS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO RESPIRATORY PROTECTION IS REQUIRED.
SELF-CONTAINED BREATHING APPARATUS IS REQUIRED IF LARGE RELEASE
OCCURS. NORMAL VENTILATION FOR STANDARD MANUFACTURING PROCEDURES IS
GENERALLY ADEQUATE.
Ventilation:LOCAL EXHAUST: USED WHEN LARGE AMOUNTS ARE RELEASED.
MECHANICAL: USE IN LOW PLACES.
Supplemental Safety and Health
NOTE TO PHYSICIANS: BECAUSE OF POSSIBLE DISTURBANCES OF CARDIAC RHYTHM,
CATECHOLAMINE DRUGS, SUCH AS EPINEPHRINE, SHOULD BE USED W/SPECIAL
CAUTION ONLY IN SITUATIONS OF EMERGENCY LIFE SUPPORT. CCL4= C ARBON
TETRACHLORIDE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:-21.6F
Vapor Pres:94.5
Vapor Density:4.26
Evaporation Rate & Reference:(CCL4 = 1): >1 SEE SUPP.
Solubility in Water:0.028%
Appearance and Odor:CLEAR, COLORLESS, LIQUIFIED GAS W/SLIGHT ETHEREAL
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALI, ALKALINE EARTH METALS, AS POWDERED ALUMINUM, ZINC, & BERYLLIUM
Stability Condition to Avoid:OPEN FLAMES, HIGH TEMPERATURES, OPEN
FLAMES, GLOWING METAL SURFACES
Hazardous Decomposition Products:HYDROCHLORIC/HYDROFLUORIC ACIDS,
CARBONYL HALIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY W/FEDERAL, STATE, & LOCAL REGULATIONS.
RECLAIM BY DISTILLATION OR REMOVE TO PERMITTED WASTE DISPOSAL
FACILITY.
| 1 |
gloves_mandatory
|
=======================================================
NIIN: 01-331-6105
Product ID: ECO SURE WHITE # 17875 (0674-170)
Cage: 0FTT5
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 0FTT5
=======================================================
Contractor Summary
=======================================================
Cage: 0FTT5
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: ENAMEL
Unit of Issue: PT
UI Container Qty: 0
=======================================================
Ingredients
=======================================================
Cas: 1330-20-7
RTECS #: ZE2100000
% Wt: <24.22
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 100 PPM
ACGIH TLV: 100 PPM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 74-98-6
RTECS #: TX2275000
% Wt: 13.96
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 1000 PPM
ACGIH TLV: 1000 PPM
------------------------------
Cas: 115-10-6
RTECS #: PM4780000
% Wt: 7.76
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Cas: 110-12-3
RTECS #: MP3850000
% Wt: 5.69
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 50 PPM
ACGIH TLV: 50 PPM
------------------------------
Cas: 64742-95-6
% Wt: 5.69
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 50 PPM
------------------------------
Cas: 64742-95-6
% Wt: <2.85
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 5 PPM
------------------------------
Cas: 107-87-9
RTECS #: SA7875000
% Wt: <2.85
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 200 PPM
ACGIH TLV: 200 PPM
------------------------------
Cas: 108-10-1
RTECS #: SA9275000
% Wt: <2.85
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 100 PPM
ACGIH TLV: 50 PPM
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 95-63-6
RTECS #: DC3325000
% Wt: <2.85
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 25 PPM
------------------------------
Cas: 4712-38-3
% Wt: <2.85
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 50 PPM
ACGIH TLV: 100 PPM
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYE: IRRIT. SKIN: IRRIT. INHAL: RESPIRATORY TRACT AND
THROAT IRRIT, HEADACHE, NAUSEA, VOMIT, HARMFUL, FATAL, BRAIN/NS DAMAGE,
ANESTHETIC, LIGHTHEADED, STAGGERING GAIT, GIDDY, NAUSEA. INGEST: HARMFUL.
Medical Cond Aggravated By Exposure: RESPIRATORY AILMENTS
First Aid: EYE: FLUSH W/WATER FOR 15 MINUTES. SKIN: WASH W/SOAP & WATER.
WASH CLOTHES BEFORE REUSE. INHAL: REMOVE TO FRESH AIR. ARTIFICIAL RESPIRATION
IF NEEDED. INGEST: DONT INDUCE VOMIT. IN ALL CASES, GET IMME D MED AID.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE IGNIT SOURCES. VENTILATE AREA. MOP SPILL
W/INERT ABSORBENT. AVOID BREATHING VAPORS.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE AND LOCAL
REGULATIONS. DONT PUNCTURE, INCINERATE OR STORE >120F. EXPOSURE TO HEAT OR
SUN MAY CAUSE CAN TO BURST. DISCARD EMPTY CAN IN TRASH PICK-UP. DONT PLAC E
IN HOME TRASH COMPACTOR.
Handling And Storage Precautions: KEEP OUT OF REACH OF CHILDREN. CAUTION:
CONTENTS UNDER PRESSURE. DONT STORE >120F.
Other Precautions: USE W/GOOD VENTILATION. READ ENTIRE LABEL BEFORE USING.
FOLLOW ALL LABEL DIRECTIONS.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: -156F,-104C
Autoignition Temp Text: 662F
Lower Limits: 2.2
Upper Limits: 18.0
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, SAND, WATER SPRAY.
AVOID SPREADING ANY BURNING LIQUID W/WATER SPRAY.
Fire Fighting Procedures: WATER MAY BE INEFFCTIVE. USE WATER TO KEEP CONTAINERS
COOL. USE SCBA. USE SHIELDING TO PROTECT AGAINST BURSTING, RUPTURING OR
VENTING OF CONTAINERS.
Unusual Fire/Explosion Hazard: DONT SPRAY NEAR OPEN FLAME. AT TEMPS >120F
CONTAINERS MAY VENT, RUPTURE OR BURST. AEROSOL CONTAINERS: DONT EXPOSE TO
TEMPS >120F.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE BELOW TLV. USE NIOSH/MSHA APPROVED MASK ABOVE TLV.
Ventilation: LOCAL EXHAUST PREFERRED. MECHANICAL (GENERAL) ACCEPTABLE AT POINT
OF MIST OR SPRAY RELEASE.
Other Protective Equipment: IMPERVIOUS CLOTHES TO PROTECT SKIN, EYEWASH
STATION.
Work Hygienic Practices: USE GOOD PERSONAL HYGIENE. DONT EAT, DRINK OR SMOKE
WHILE USING PRODUCT.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: NA
M.P/F.P Text: NA
Decomp Text: NA
Vapor Pres: 70 @ 68F
Vapor Density: >1.522
Spec Gravity: 0.903 AEROSOL
PH: NA
VOC Grams/Liter: 584
Viscosity: NA
Solubility in Water: INSOLUBLE
Appearance and Odor: WHITE PAINT
Corrosion Rate: NA
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: EXTREME HEAT
Materials To Avoid: NA
Hazardous Decomposition Products: CARBON MONOXIDE
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NA
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: VOC = 584 G/L
=======================================================
Transportation Information
=======================================================
Trans ID NO: 126031
Product ID: ECO SURE WHITE # 17875 (0674-170)
Review Date: 04/13/1998
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: PT
Container QTY: 0
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: DTJ
Symbols: D
DOT Proper Shipping Name: CONSUMER COMMODITY
Hazard Class: ORM-D
Label: NONE
Non Bulk Pack: 156,306
Bulk Pack: NONE
Max Qty Pass: 30KGGROSS
Max Qty Cargo: 30KGGROSS
Vessel Stow Req: A
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: AKH
IMO Proper Shipping Name: AEROSOLS/AEROSOL PRODUCT ?
IMDG Page Number: SEE 9022
UN Number: 1950
UN Hazard Class: 9?
IMO Packaging Group: -
Subsidiary Risk Label: -
EMS Number: 2-13
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ALS
IATA UN ID Num: 1950
IATA Proper Shipping Name: AEROSOLS, FLAMMABLE
IATA PSN Modifier: (EACH NOT EXCEEDING 1 L CAPACITY)
IATA UN Class: 2.1
IATA Label: FLAMMABLE GAS
Packing Note Passenger: 203
Max Quant Pass: 75KG
Max Quant Cargo: 150KG
Packaging Note Cargo: 203
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ALR
AFI Symbols: *
AFI Proper Shipping Name: AEROSOLS, FLAMMABLE, N.O.S.
AFI PSN Modifier: (EACH NOT EXCEEDING 1L CAPACITY)
AFI Hazard Class: 2.1
AFI UN ID NUM: UN1950
Special Provisions: P4
Back Pack Reference: A6.3
=======================================================
HAZCOM Label
=======================================================
Product ID: ECO SURE WHITE # 17875 (0674-170)
Cage: 0FTT5
Company Name: LHB INDUSTRIES
Street: 8833 FLEISCHER PLACE
Zipcode: 63134
Label Required IND: Y
Date Of Label Review: 10/12/1999
Status Code: A
Origination Code: G
Hazard And Precautions: EYE: IRRIT. SKIN: IRRIT. INHAL: RESPIRATORY TRACT AND
THROAT IRRIT, HEADACHE, NAUSEA, VOMIT, HARMFUL, FATAL, BRAIN/NS DAMAGE,
ANESTHETIC, LIGHTHEADED, STAGGERING GAIT, GIDDY, NAUSEA. INGEST: HARMFUL.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:COAL TAR POLYURETHANE 808
CAGE:37512
CAGE:37512
============= Composition/Information on Ingredients =============
Ingred Name:REFINED COAL TAR
CAS:65996-90-9
Fraction by Wt: 45%
Ingred Name:POLYURETHANE
Fraction by Wt: 55%
Ingred Name:TOLUENE DIISOCYANATE
CAS:26471-62-5
RTECS #:HQ9490000
Fraction by Wt: TRACE
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:LIQUID PETROLEUM RESIN
Fraction by Wt: <7%
Ingred Name:AROMATIC HYDROCARBONS
CAS:70955-17-8
Fraction by Wt: <7%
Ingred Name:POLYURETHANE
CAS:68400-67-9
Fraction by Wt: <3%
Ingred Name:FREE ISOCYANATE GROUPS
Fraction by Wt: <3%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. OXYGEN IF NECESSARY. SKIN:
WASH W/SOAP & WATER. EYES: FLUSH W/WATER FOR AT LEAST 15 MINS.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:240F
Extinguishing Media:FOAM, CO2, OR DRY CHEMICAL
Unusual Fire/Explosion Hazard:DANGEROUS WHEN EXPOSED TO HEAT OR FLAME
AS IT CAN REACT VIGOROUSLY TO OXIDIZING MATERIAL & WHEN HEATED TO
DECOMPOSITION EMIT HIGHLY TOXIC FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. ABSORB ON CHEMICAL ABSORPTIVE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:BUREAU OF MINES OR NIOSH APPROVED RESPIRATOR
Ventilation:USE ONLY IN WELL VENTILATED AREA
Other Protective Equipment:COVERALLS, OR CLOTHING COVERING
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, AMMONIA, OXIDIZING MATERIALS
Stability Condition to Avoid:HEAT OR FLAME, SOURCES OF IGNITION
Hazardous Decomposition Products:CO
==================== Disposal Considerations ====================
Waste Disposal Methods:SUPERVISED INCINERATION W/AFTER-BURNER OR
SCRUBBER OR DISPOSAL AREA W/APPLICABLE STATE, LOCAL, & FEDERAL
REGULATIONS
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ENSOLITE TYPE LSC
CAGE:KO770
CAGE:89616
CAGE:KO770
============= Composition/Information on Ingredients =============
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
Effects of Overexposure:ENSOLITE DOES NOT PRESENT ANY KNOWN HEALTH
HAZARD UNDER NORMAL CONITIONS OF USE. SEE ALSO SECTION IX
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CO*2
Fire Fighting Procedures:FIREFIGHTERS SHOULD USE SELF-CONTAINED
BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:COMBUSTION PROD. SHOULD BE CONSIDERED
TOXIC. TOXIC FIRE/GAS HAZARD INCL. HCL, A PULMONARY IRRITANT.
================== Accidental Release Measures ==================
Spill Release Procedures:ACCORDING TO MANUFACTURER NO SPECIAL STEPS
NECESSARY.
======================Handling and Storage ======================
Handling and Storage Precautions:BEST STORED IN COOL, DRY LOCATION.
NORMALLY NO OTHER PRECAUTIONS NEEDED FOR ORDINARY HANDLING OR
STORAGE.
Other Precautions:FOR HOT PROCESSING(ABOVE 175F,79C E.G. THERMOFORMING)
ARE RECOMMENDED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SEE SECTION IX
Ventilation:SEE SECTION IX
Supplemental Safety and Health
DENSITY(POUNDS/CUBIC FOOT):4.5 TO 8.5. MANUFACTURER SPECIFIES EACH
SHEET TO MEASURE 42" X 56" AND 1/4" THICK.
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:NIL
Appearance and Odor:CLOSED CELL PVC/NITRILE FOAM, NEGLIGIBLE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Hazardous Decomposition Products:THERMDECOMP:POS ORGANIC&INORG HALOGEN
CMPD,CO**,CYANIDE CMPD
==================== Disposal Considerations ====================
Waste Disposal Methods:BURY IN AN APPROVED LANDFILL SITE IN ACCORDANCE
WITH APPLICABLE LOCAL, STATE, AND FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ORGANIC PHOTOCONDUCTOR FO-52DR
CAGE:0BDN7
CAGE:0BDN7
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM; (ALUMINUM CYLINDER)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: >97%
OSHA PEL:15MG/M3 TDUST;5 FUME
ACGIH TLV:10 MG/M3 DUST;5 FUME
Ingred Name:BINDER RESIN
Fraction by Wt: <1%
Ingred Name:PHOTOSENSITIVE MATERIAL
Fraction by Wt: <1%
Ingred Name:PIGMENT
Fraction by Wt: <1%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NONE
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMEDIATELY . INHAL: REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE OXYGEN/ARTIFICIAL RESPIRATION) CALL MD .
EYES: IMMEDIATELY FLUSH W/POTABLE WATER FOR A MINIMUM OF 15 MINUT
ES, SEEK ASSISTANCE FROM MD . SKIN: FLUSH WITH COPIOUS AMOUNTS OF
WATER. CALL MD .
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM OR WATER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . THIS MATERIAL WILL BE SCORCHED IN THE CASE
OF FIRE.
Unusual Fire/Explosion Hazard:THIS MATERIAL HAS NO UNUSUAL FIRE OR
EXPLOSION HAZARDS.
================== Accidental Release Measures ==================
Spill Release Procedures:NO SPECIAL PRECAUTION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL STORAGE REQUIREMENTS FOR
SAFETY REASONS.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL USE. NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE REQUIRED.
Other Protective Equipment:NONE REQUIRED UNDER NORMAL USE.
Work Hygienic Practices:NONE
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:2.7 (H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GREEN, ODORLESS AND SOLID CYLINDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MATERIAL MAY BE DUMPED OR INCINERATED
UNDER CONDITION WHICH MEETS ALL FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGULATIONS.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:PREMIUM OUTBOARD AND MULTI-PURPOSE 2-CYCLE OIL
Preparer's Name:MSDS CODE:00681
CAGE:01326
CAGE:0DX84
CAGE:01326
============= Composition/Information on Ingredients =============
Ingred Name:LUBRICATING OIL BASE
Fraction by Wt: 75-85%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DETERGENT/INHIBITOR SYSTEM (TRADE SECRET)
Fraction by Wt: 15-25%
Other REC Limits:NONE RECOMMENDED
Ingred Name:OIL SOLUBLE DYE (TRADE SECRET)
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:PEL OIL MIST IS 5MG/M3
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:DIRECT CONTACT SLIGHTLY
IRRITATING.SKIN:DIRECT CONTACT MAY CAUSE SLIGHT
IRRITATION,SENSITIZATION.MAY BE ABSORBED THROUGH THE
SKIN.INHAL:HIGH CONCENTRATIONS MAY CAUSE RESPIRATORY TRACT
IRRITATION, INTOXICATION,ASPHYXIATION(IF HIGH ENOUGH TO DISPLACE
OXYGEN).INGEST:MAY CAUSE LUNG DAMAGE IF VOMITED AFTER SWALLOWING.
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of Overexposure:SKIN:DERMATITIS(REDDENING,DRYNESS,CHAPPING),OIL
ACNE(B;ACKHEADS.INHAL:DROWSINESS,DULLNESS,NUMBNESS,HEADACHE
...THEN,DIZZINESS,WEAKNESS,NAUSEA,UNCONSCIOUSNESS,CONVULSIONS,DEATH
.INGEST:SEVERE ORAL INTOX ICATION WILL LEAD TO BURNING OF THE
THRAOT AND SYMPTOMS SIMILAR TO INHALATION.ITEM IS
LAXATIVE(CRAMPS,DIARRHEA).
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING
RESPIRATORY AILMENTS MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH LARGE AMOUNTS OF WATER UNTIL IRRITATION
SUBSIDES.SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH SOAP AND
WATER.USE HAND LOTION FOR DRYNESS.CALL PHYSICIAN IF REDNESS OR
IRRITATION OCCURS.I NHAL:REMOVE TO FRESH AIR.GIVE OXYGEN,ARTIFICIAL
RESPIRATION AND GET MEDICAL AHELP IF NEEDED.INGEST:DO NOT INDUCE
VOMITING.IF SPONTANEOUS VOMITING OCCURS,KEEP HEAD LOWER THNA HIPS.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:273F,134C
Extinguishing Media:DRY CHEMICAL,FOAM,CARBON DIOXIDE.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.COOL FIRE EXPOSED CONTAINERS WITH WATER
SPRAY.
Unusual Fire/Explosion Hazard:FIRE CONDITIONS MAY EVOLVE TOXIC FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION.VENTILATE AREA.SOAK
UP WITH AN INERT,NON-COMBUSTIBLE ABSORBANT(EG.SAND,CLAY).PICK UP
LARGE SPILLS WITH A VACUUM TRUCK.PLACE IN AN APPROPRIATE CONTAINER
FOR DISPOSAL.DO NOT A LLOW PRODUCT TO ENTER SEWER OR WATERWAY.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,WELL-VENTILATED
PLACE,AWAY FROM HEAT,SPARKS,FLAMES,OXIDIZING AGENTS.
Other Precautions:DO NOT TRANSFER TO UNMARKED CONTAINERS;MATERIEL IS
CLASSIFIED AS COMBUSTIBLE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF CONCENTRATION IS LESS THAN 10X TLV,USE AN
ORGANIC VAPOR CARTRIDGE RESPIRATOR.IF GREATER THAN 10X TLV,USE AN
AIR SUPPLIED RESPIRATOR.DO NOT USE COMPRESSED OXYGEN IN AN
HYDROCARBON ATMOSPHERE.
Ventilation:USE GENERAL DILUTION VENTILATION.EQUIPMENT SHOULD BE
EXPLOSION PROOF.
Other Protective Equipment:CLOTHING TO AVOID SKIN CONTACT.
Work Hygienic Practices:WASH HANDS.SEPERATE WORK CLOTHES FROM STREET
CLOTHES.LAUNDER WORK CLOTHES BEFORE REUSE.KEEP FOOD OUT OF THE WORK
AREA.
Supplemental Safety and Health
CONSUMPTION OF FFOD OR BEVERAGES SHOULD BE AVOIDED IN THE WORK PLACE
WHERE HYDROCARBONS ARE PRESENT.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:>300F,>149C
Vapor Density:4-5 AIR=1
Spec Gravity:0.85
Appearance and Odor:LIQUID;GRREN/BLUE;ODOR NOT REPORTED
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:MANUFACTURER STATES NONE.
Hazardous Decomposition Products:CARBON DIOXIDE,CARBON MONOXIDE,DENSE
SMOKE,UNIDENTIFIED OXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.MAY BE CONSIDERED RCRA HAZARDOUS WASTE.RECYCLE IF
POSSIBLE.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ARGON (REFRIGERATED LIQUID), L-4564-E
CAGE:0LV01
CAGE:0LV01
============= Composition/Information on Ingredients =============
Ingred Name:ARGON
CAS:7440-37-1
RTECS #:CF2300000
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:ASPHYXIANT; 9495
Ingred Name:SUPDAT:CONTROL OF SYMPTOMS AND CLINICAL CONDITION.
RTECS #:9999999ZZ
Ingred Name:SPILL RELEASE:FOR SUFFICIENT OXYGEN CONTENT PRIOR TO
PERMITTING RE-ENTRY OF PERSONNEL.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:EMPTY. USE PIPING & EQUIP ADEQ DESIGNED TO
WITHSTAND PRESS & TEMP TO BE ENCOUNTERED. DO NOT GET LIQ (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:IN EYES, ON SKIN/CLTHG. DO NOT STRIKE ARC ON CNTNR.
DO NOT GROUND CNTNR/ALLOW TO BECOME PART OF ELEC (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:CIRCUIT. MIXTURES:WHEN 2 OR MORE GASES/LIQUEFIED
GASES ARE MIXED, THEIR HAZ PROPERTIES MAY COMBINE TO (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:CREATE ADDNL, UNEXPECTED HAZ. OBTAIN & EVALUATE SFTY
INFO FOR EACH COMPONENT BEFORE YOU PRDCE MIX. CONSULT (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:INDUST HYGIENIST/OTHER TRAINED PERSON WHEN YOU MAKE
YOUR SFTY EVALUATION OF END PROD. REMEMBER, GASES & (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:LIQS HAVE PROPERTIES WHICH CAN CAUSE SERIOUS
INJURY/DEATH. BE SURE TO READ & UNDERSTAND ALL LBLS & OTHER (ING
10)
RTECS #:9999999ZZ
Ingred Name:ING 9:INSTRUCTIONS SUPPLIED W/ALL CNTNRS OF THIS PROD.
NOTE:COMPATIBILITY W/PLASTICS SHOULD BE CONFIRMED PRIOR (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:TO USE. FOR SFTY INFO ON GEN HNDLG OF COMPRESSED GAS
CYLS, OBTAIN COPY OF PAMPHLET P-1, "SAFE HNDLG OF (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:COMPRESSED GAS IN CNTNRS," PAMPHLET P-12, "SAFE
HNDLG OF CRYOGENIC LIQS" & PAMPHLET P-9, "THE INERT (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:GASES, ARGON, NITROGEN, & HELIUM," FROM THE
COMPRESSED GAS ASSOCIATION, INC.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:SUPPLIED RESP IS REQD WHILE WORKING IN CONFINED
SPACES. RESP PROT USE MUST CONFORM W/OSHA RULES AS (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:SPECIFIED IN 29 CFR 1910.134.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INGEST: UNLIKELY RTE OF EXPOS,
BUT FROSTBITE OF LIPS & MOUTH MAY RSLT FROM CONT W/LIQ. INHAL:
ASPHYXIANT. MODERATE CONC MAY CAUSE HEADACHE, DROWSINESS,
DIZZINESS, EXCITATION, EXCESS SALIVATION, VOMITING AND
UNCONSCIOUSNESS. SKIN: LIQUID MAY CAUSE FROSTBITE. EYE: LIQUID MAY
CAUSE FROSTBITE. OTHER (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HEALTH HAZARDS: EFFECTS OF OVEREXPOSURE: ARGON
IS AN ASPHYXIANT. LACK OF OXYGEN CAN CAUSE DEATH.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INGEST:THIS PROD IS GAS @ NORM TEMP & PRESS. SKIN:IMMED WARM
FROSTBITE AREA W/WARM WATER (NOT TO EXCEED 105F). IN CASE OF
MASSIVE EXPOS, REMOVE CLTHG WHILE SHOWERING W/WARM WATER. CALL
PHYS. INHAL:REM OVE TO FRESH AIR. GIVE ARTF RESP IF NOTBRTHG. GIVE
OXYG IF BRTHG IS DFCLT. CALL PHYS. EYE:IMMED FLUSH THORO W/WATER
FOR @ LEAST 15 MINS. SEE PHYS, PREF OPHTHALMOLOGIST, IMMED. NOTE TO
PHYS: (SUP DAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:ARGON CANNOT CATCH FIRE. USE MEDIA APPROPRIATE FOR
SURROUNDING FIRE.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
EVAC ALL PERS FROM DANGER AREA. IMMED DELUGE CNTNRS W/WATER SPRAY
FROM MAX DIST UNTIL COOL, THEN MOVE (SUPDAT)
Unusual Fire/Explosion Hazard:LIQ/VAP CANNOT CATCH FIRE. CLSD CNTNR MAY
RUPTURE DUE TO HEAT OF FIRE. LIQ ARGON WILL FREEZE WATER RAPIDLY.
CNTNRS ARE PROVIDED W/PRESS RELIEF DEVICE (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:CAUTION:ARGON GAS IS ASPHYXIANT. EVAC ALL PERS
FROM DANGER AREA. ALLOW SPILLED LIQ TO EVAP. SHUT OFF LEAK IF W/OUT
RISK. MOVE LEAKING ASSEMBLY TO VENT AREA OF LEAK. USE NIOSH/MSHA
APRD SCBA WHERE NEED ED. TEST AREA, ESPECIALLY CONFINED AREA, (ING
3)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NEVER WORK ON PRESSURIZED SYSTEM. IF
THERE IS LEAK, CLOSE CYL VALVE, BLOW DOWN SYSTEM BY VENTING TO SAFE
PLACE, THEN REPAIR LEAK.
Other Precautions:WARNING:EXTREMELY COLD LIQ & GAS. CONT W/LIQ OR COLD
GAS CAUSES SEV FROSTBITE. VAP CAN CAUSE RAPID SUFFOCATION DUE TO
OXYG DEFICIENCY. PROTECT CNTNRS AGAINST PHYSICAL DMG. STORE & USE
W/ADEQ VENT. CLO SE VALVE WHEN NOT IN USE & WHEN (ING 4)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD AIR-PURIFYING/NIOSH/MSHA
APPRVD AIR-SUPPLIED RESP, AS APPROP, WHERE LOC &/OR GEN EXHAUST
VENT IS NOT ADEQ TO KEEP WORKER EXPOS BELOW APPLIC TLVS DURING
WELDING OPERATIONS USING ARGON . NIOSH/MSHA APPRVD AIR (ING 14)
Ventilation:LOCAL EXHAUST AND MECHANICAL (GENERAL).
Other Protective Equipment:METATARSAL SHOES. CUFFLESS TROUSERS. ANSI
APPROVED EMERGENCY EYE WAS AND DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPEC GRAV:1.40 @ -185.9C (H*2O=1). FIRE FIGHT PROC:CNTNRS AWAY FROM
FIRE AREA IF W/OUT RISK. DO NOT DISCHARGE SPRAYS INTO LIQ ARGON.
EXPLO HAZ:DESIGNED TO VENT CONTENTS WHEN THEY ARE EXPOS TO ELEVATED
TEMP. FIRST AID PROC:PROD IS INERT. THERE IS NO SPECIFIC ANTIDOTE.
TREATMENT OF OVEREXP SHOULD BE DIRECTED AT (ING 2)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:-303F,-186C
Melt/Freeze Pt:M.P/F.P Text:-309F,-189C
Vapor Pres:GAS @ 20C
Vapor Density:1.378 @70F
Spec Gravity:SUPDAT
Evaporation Rate & Reference:HIGH (BUTYL ACETATE =1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS, ODORLESS CRYOGENIC LIQUID.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE CURRENTLY KNOWN. ARGON IS CHEMICALLY INERT.
Stability Condition to Avoid:HEAT.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS . SLOWLY RELEASE INTO ATMOSPHERE
OUTDOORS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:LIGHT CURING DENTAL RESTORATIVE 2972
CAGE:64397
CAGE:64397
============= Composition/Information on Ingredients =============
Ingred Name:AROMATIC AND ALIPHATIC DIMETHACRYLATE MONOMERS
Fraction by Wt: 21.78%
Ingred Name:LITHIUM ALUMINUM SILICATE
CAS:1302-66-5
RTECS #:OJ5580000
Fraction by Wt: 75.0%
ACGIH TLV:2 MG/CUM
Ingred Name:SILICA
CAS:7631-89-9
Fraction by Wt: 1.5%
Ingred Name:SILICON TETRAHYDRIDE
CAS:7803-62-5
RTECS #:VV1400000
Fraction by Wt: 1-2%
Other REC Limits:5 PPM
OSHA PEL:5 PPM
ACGIH TLV:5 PPM; 9192
Ingred Name:ACTIVATORS
Fraction by Wt: <1.0%
Ingred Name:STABILIZERS
Fraction by Wt: <1.0%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RATS LD50 = >5000 MG/KG
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: REPEATED
CONTACT MAY CAUSE REDDENING & IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION. SKIN: REPEATED CONTACT MAY
CAUSE REDDENING & IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH COPIOUS QUANTITIES OF WATER FOR 15 MIN. SEEK
MED ATTN. SKIN: WASH WITH SOAP/WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:USE PROTECTIVE GEAR. USE WATER FOG TO COOL
LARGE CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:MATERIAL MAY BURN IF EXPOSED TO FLAME.
KEEP AWAY FROM IGNITION SOURCES.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP OR SCOOP UP & STORE IN APPROPRIATE
CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM IGNITION SOURCES.
PROTECT FROM HIGH HEAT. KEEP CONTAINERS CLOSED WHEN NOT IN USE.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Other Protective Equipment:NONE
Work Hygienic Practices:NONE
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
Spec Gravity:2.1
Appearance and Odor:TRANSLUCENT TO OPAQUE PASTE; CHARACTERISTIC
METHACRYLATE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:IGNITION SOURCES, HEAT, ELEVATED
TEMPERATURES, FLAME.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL REGULATIONS FOR
RELATIVELY NON-TOXIC ORGANICS. DON'T INCINERATE.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:DIRASOL 125 EMULSION,DJ-L 27
CAGE:SERIC
CAGE:0Z2D3
CAGE:SERIC
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN. ACUTE-
INHALATION NOT LIKELY AT ROOM TEMPERATURES. MAY CAUSE IRRITATION OF
EYES. SKIN IRRITATION MAY OCCUR IN SENSITIVE INDIVIDUALS. MAY CAUSE
GASTROINTESTINAL TRACT IRRITATI ON, IF INGESTED. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALATION:REMOVE TO
FRESH AIR. EYES:FLUSH WITH WATER FOR 15 MINUTES, HOLDING EYELIDS
OPEN. SKIN:WASH WITH SOAP & WATER. INGESTION:DO NOT INDUCE
VOMITING. DRINK T WO GLASSES OF WATER. GET MEDICAL ATTENTION
IMMEDIATELY. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>200F,>93C
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, ALCOHOL FOAM, WATER
FOG. COOL FIRE-EXPOSED CONTAINERS WITH WATER SPRAY.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:DECOMPOSITION PRODUCTS MAY BE HAZARDOUS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ABSORB SPILL WITH
INERT MATERIAL SUCH AS VERMICULITE. PLACE IN A CONTAINER FOR
DISPOSAL. CLEAN AREA THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM INCOMPATIBLE
MATERIALS. AVOID PROLONGED STORAGE AT TEMPERATURES IN EXCESS OF
100F.
Other Precautions:DO NOT GET IN EYES, ON SKIN OR ON CLOTHING. WASH
THOROUGHLY AFTER HANDLING AND BEFORE EATING OR DRINKING. REMOVE
CONTAMINATED CLOTHING PROMPTLY. LAUNDER BEFORE REUSE. KEEP OUT OF
REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXCESSIVE MISTING IS EXPECTED, WEAR
NIOSH-APPROVED RESPIRATORY PROTECTION (REFER TO 29 CFR 1910.134).
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP MIST OR
VAPOR LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWERS SHOULD BE
AVAILABLE IN THE IMMEDIATE VICINITY OF ANY POTENTIAL EXPOSURE.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:<1 @ 68F
Vapor Density:>1
Spec Gravity:1.064
Evaporation Rate & Reference:1 (WATER=1)
Solubility in Water:100%
Appearance and Odor:BLUE LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MATERIALS THAT REACT WITH WATER
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, BLACK
SMOKE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:BIOSPERSE (R) 255 MICROBIOCIDE, 4303269
CAGE:IO080
CAGE:IO080
CAGE:52454
============= Composition/Information on Ingredients =============
Ingred Name:GLUTARALDEHYDE
CAS:111-30-8
RTECS #:MA2450000
Fraction by Wt: 15%
ACGIH TLV:0.2 PPM, C (MFR)
Ingred Name:HNDLG/STOR PREC:& HNDLD IN BAKED PHENOLIC-LINED STEEL
POLYETHYLENE, STAINLESS STEEL, OR REINFORCED EPOXY- (SEE ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2:PLASTIC EQUIP. PROD FREEZES AT ABOUT 1.4F. THEREFORE,
UNLESS STOR TANK IS INSIDE/UNDERGROUND, HEATING (SEE ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:&INSULATION MAY BE REQUIRED. IF HEATING NEEDED, EXPOS
TO HIGH TEMPS SHOULD BE AVOIDED. FOR SHORT STOR (SEE ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:TIMES (UP TO ABOUT 1 MO), TEMPS OF UP TO 100F CAN BE
TOLERATED BUT PREFERRED MAX STOR TEMP IS ABOUT 80F.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:SPECIFIED CONDS. ENGINEERING/ADMINISTRATIVE
CONTROLS SHOULD BE IMPLEMENTED TO REDUCE EXPOSURE.
RTECS #:9999999ZZ
Ingred Name:EYE PROT:AND FACESHIELD (8" MIN) IN COMPLIANCE W/OSHA
REGULATIONS ADVISED.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES:CAN CAUSE SEVERE
IRRITATION, CORNEAL BURNS AND CONJUNCTIVITIS. SKIN:CAN CAUSE
IRRITATION. BURNS CAN RESULT FROM PROLONGED CONTACT. CAN BE
ABSORBED IN TOXIC AMOUNTS, ESPECIALLY FROM PRLNGD/R PTD EXPOSURE.
INHAL:VAPOR IS IRRITATINGTO RESPIRATORY TRACT CAUSING STINGING
SENSATIONS IN NOSE (SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:& THROAT, COUGHING, CHEST DISCOMFORT &
TIGHTNESS, DIFFICULTY W/BREATHING & HEADACHE. INGEST:MAY CAUSE
MODERATE TO SEVERE IRRITATION OR BURNS OF MOUTH, THROAT, ESOPHAGUS
& STOMACH W/ABDOMINAL & CHEST DISCOMFORT/PAIN, NAUSEA, VOMITING,
DIARRHEA, DIZZINESS, FAINTNESS, WEAKNESS, CIRCULATORY SHOCK &
COLLAPSE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN:IMMED FLUSH EXPOSED AREA W/WATER FOR AT LEAST 15 MIN,
GET MD. REMOVE CONTAMD CLTHG. WASH CONTAMD CLTHG BEFORE RE- USE.
EYE:IMMED FLUSH W/LG AMTS OF WATER FOR AT LEAST 15 MIN, LIFTING
LIDS OCCSNLY . GET MD IMMED. INGEST:DO NOT INDUCE VOMIT. VOMIT WILL
CAUSE FURTHER DMG TO THROAT. DILUTE BY GIVING WATER. GIVE MILK OF
MAGNESIA. KEEP WARM, QUIET.GET MD IMMED. NOTE TO MD:PROBABLE
MUCOSAL (SUPP DATA
===================== Fire Fighting Measures =====================
Extinguishing Media:ALCOHOL FOAM, WATER FOG, CARBON DIOXIDE OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:SML:ABSORB LIQ ON PAPER, VERMICULITE, FLOOR
ABSORB/OTHER ABSORB MATL & TRANSFER TO HOOD. LG:PERS NOT WEARING
PROT EQUIP SHOULD BE EXCLUDED FROM AREA OF SPILL UNTIL CLEAN-UP
COMPLETED. DECONTAM SPILLED MATL BY CAREFUL APPLICATION OF
AQUEOUS(SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PROD SOLNS CORR TO MANY COMMONLY USED
MATLS OF CONSTRUCTION (STEEL,GALVANIZED IRON,ALUMINUM,TIN & ZINC).
THESE SOLNS CAN BE STORED (SEE ING 2)
Other Precautions:CNTNRS OF MATL MAY BE HAZ WHEN EMPTIED SINCE EMPTIED
CNTNRS RETAIN PROD RESIDUES (VAP/LIQ,&/OR SOLID), ALL HAZ
PRECAUTIONS GIVEN MUST BE OBSERVED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF WORKPLACE EXPOS LIM OF PROD/ANY COMPONENT IS
EXCEEDED, A NIOSH/MSHA APPRVD AIR SUPPLIED RESP IS ADVISED IN
ABSENCE OF PROPER ENVIRONMENTAL CONTROL. OSHA REGS ALSO PERMIT
OTHER NIOSH/MSHA APPRVD RES P (NEG PRESS TYPE) UNDER (SEE ING 6)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL &/OR LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:TO PREVENT SKIN CONTACT, WEAR IMPERVIOUS
CLOTHING AND BOOTS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PH:3.7-4.5. FIRST AID PROC:DMG MAY CONTRAINDICATE USE OF GASTRIC
LAVAGE. INHAL:REMOVE TO FRESH AIR. IF BRTHG DFCLT,GIVE O2. IF BRTHG
STOPPED,GIVE ARTF RESP. KEEP WARM/QUIET & GET MD. SPILL PROC:AMMONI
UM HYDROXIDE/SODIUM BISULFITE SOLN. CONSIDERABLE HEAT & FUMES CAN
BE LIBERATED BY DECONTAM RXN.
================== Physical/Chemical Properties ==================
HCC:C3
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:18.10
Vapor Density:0.7
Spec Gravity:1.030-1.044
pH:SUPDAT
Evaporation Rate & Reference:SLOWER THAN ETHER.
Appearance and Odor:CLEAR & COLORLESS LIQUID.
Percent Volatiles by Volume:80-85
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES & ACIDS CATALYZE AN ALDOL-TYPE CONDENSATION
(EXOTHERMIC, BUT NOT EXPECTED TO BE VIOLENT).
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:THERMAL DECOMPOSITION OR COMBUSTION
MAY PRODUCE CO2 OR CO.
Conditions to Avoid Polymerization:POLYMERIZATION CAN OCCUR BUT AT
TEMPERATURES BELOW BOILING POINT OF WATER, IT IS NOT CONSIDERED
HAZARDOUS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W ALL LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:MIL-C-83286, 24300, S/G P/N 03GN076
Kit Part:Y
Preparer's Name:NORM GAUL
CAGE:5M511
CAGE:33461
CAGE:5M511
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL 3-ETHOXYPROPIONATE (VAPOR PRESSURE 0.7 MM HG @ 68F)
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: 20%
Other REC Limits:50 PPM; STEL 100 PPM
Ingred Name:C8&10 AROMATIC HYDROCARBON (VAPOR PRESSURE 3 MM HG @ 68F)
CAS:64742-95-6
Fraction by Wt: <1%
Other REC Limits:MFR PEL: 100 PPM
Ingred Name:DISPERSION AGENT (VAPOR PRESSURE 0 MM HG)
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ANTI FLOAT AGENT (VAPOR PRESSURE 0 MM HG)
CAS:1317-65-3
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MP/F3
ACGIH TLV:10 MP/F3
Ingred Name:ETHYL ACETATE (SARA III) (VAPOR PRESSURE 86 MM HG @ 68F)
CAS:141-78-6
RTECS #:AH5425000
Fraction by Wt: 15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE (SARA III) (VAPOR PRESSURE 70 MM HG @
68F)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 7.48%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM;STEL 300 PPM
ACGIH TLV:200 PPM;STEL 300 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ANTI MAR AGENT (VAPOR PRESSURE 0 MM HG)
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:XYLENE (SARA III) (VAPOR PRESSURE 21 MM HG @ 100F)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 0.05%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM;STEL 150 PPM
ACGIH TLV:100 PPM;STEL 150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE (SARA III) (VAPOR PRESSURE 7.1 MM HG @ 68F)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 0.02%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM;STEL 125 PPM
ACGIH TLV:100 PPM;STEL 125 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:DIBUTYLTIN DILAURATE (VAPOR PRESSURE 0.2 MM HG @ 320F)
CAS:77-58-7
RTECS #:WH7000000
Fraction by Wt: <0.1%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:0.1 MG/M3
Ingred Name:VOC: 529 G/L
ACTUAL VOC DETERMINED PER EPA REFERENCE METHOD 24
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: RESP TRACT IRRIT, ACUTE NERVOUS
SYS DEPRESSN (HEADACHE, DIZZY, STAGGERING, CONFUSION, UNCONSCIOUS,
COMA). SKIN: IRRIT (SWELL, RED, RASH). ABSORPTION: IRRIT, DRYING,
DEFATTING (CRACKING). EYE: I RRIT (TEARING, RED, SWELL W/STING).
INGEST: IRRIT, CORROSIVE IN GI TRACT. VOMITING MAY CAUSE
ASPIRATION-CHEM PNEUMONITIS
Effects of Overexposure:ACUTE: VAPORS ARE IRRITATING TO EYES, NOSE, &
THROAT. INHALATION MAY CAUSE HEADACHES, DIFFICULT BREATHING & LOSS
OF CONSCIOUSNESS. CHRONIC: PROLONGED CONTACT WILL CAUSE
DRYING AND CRACKING OF TH E SKIN, DUE TO DEFATTING ACTION. SKIN
SENSITIZATION, ASTHMA OR OTHER ALLERGIC RESPONSES MAY DEVELOP.
Medical Cond Aggravated by Exposure:HARMFUL IF SWALLOWED OR ABSORBED
THROUGH SKIN. MAY CAUSE LIVER AND KIDNEY DAMAGE.
======================= First Aid Measures =======================
First Aid:INHAL: MOVE TO FRESH AIR. RESTORE BREATHING. ASTHMATIC TYPE
SYMPTOMS MAY DEVELOP (IMMED/DELAYED). GET MEDICAL ATTENTION. SKIN:
REMOVE CONTAMINATED CLOTHING. WASH W/SOAP & WATER. WASH CONTAM
CLOTHING B EFORE REUSE. EYES: FLUSH W/CLEAN LUKEWARM WATER (LOW
PRESSURE) 15 MIN, OCCASIONALLY LIFT EYELID. GET MED AID. INGESTION:
DON'T INDUCE VOMITING. NOTHING BY MOUTH TO UNCONSCIOUS PERSON. GET
MEDICAL AID.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:23.0F,-5.0C
Lower Limits:1.00
Upper Limits:11.00
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG,
WATER SPRAY
Fire Fighting Procedures:WEAR FULL FIRE FIGHTING EQUIP W/SCBA & FULL
PROTECTIVE CLOTHING. USE WATER TO COOL CLOSED CONTAINERS TO PREVENT
PRESSURE BUILD-UP, AUTO IGNITION, OR EXPLOSION.
Unusual Fire/Explosion Hazard:KEEP CNTNR CLSD. KEEP FROM HEAT/IGNIT
SOURCE. CLSD CNTNR MAY EXPLODE W/HEAT. APPLIC TO HOT SURFACE REQ
SPECIAL PRECAUTION. OVEREXPOSURE TO DECOMP PROD-HLTH HZD.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE
ALL SOURCES OF IGNITION (FLAME, SPARK SOURCES, HOT SURFACES).
VENTILATE AREA. CONTAIN AND REMOVE WITH INERT ABSORBENT AND
NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN BUILDINGS DESIGNED TO COMPLY
WITH OSHA 1910.106. AVOID STORING NEAR HIGH TEMPERATURES/IGNITION
SOURCES. STORE IN CLSD CNTNR IN VENTED AREAS.
Other Precautions:KEEP CNTNR TIGHT & UPRIGHT (PREVENT LEAK). PREVENT
PROLONGED VAPOR BREATHING. PROLONGED OVEREXPOSURE MAY CAUSE
ALLERGIC REACTION. AVOID CONTACT W/SKIN & EYES. DON'T INGEST. DON'T
HANDLE TILL MFR SFTY PRECAUTIONS HAVE BEEN READ & UNDERSTOOD.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR RECOMMENDED FOR ORGANIC VAPOR
ENVIRONMENT (AIR PURIFYING OR FRESH AIR SUPPLIED). OBEY OSHA REGS
FOR RSPRTR USE. PROVIDE VENT TO KEEP EXPOSURE LEVELS BELOW PEL. IF
TLV MAINTAIN, OTHER OSHA/N IOSH RESPIRATOR MAY BE USED.
Ventilation:EXHAUST VENT TO KEEP AIRBORNE CONCENTRATIONS BELOW TLV'S.
REMOVE ALL IGNITION SOURCES.
Other Protective Equipment:THE USE OF LONG SLEEVE AND LONG LEG CLOTHING
IS RECOMMENDED. REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
WASHROOM. SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:169 TO 401F
Vapor Density:> AIR
Spec Gravity:1.2521
Viscosity:*
Evaporation Rate & Reference:2.06 X N-BUTYL ACETATE
Solubility in Water:INSOLUBLE
Appearance and Odor:GREEN LIQUID WITH SOLVENT ODOR
Percent Volatiles by Volume:58.4
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, OR OPEN FLAMES
Hazardous Decomposition Products:BY HIGH HEAT/TEMPERATURE: CARBON
MONOXIDE, CARBON DIOXIDE, AND OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORD WITH FEDERAL, STATE,
& LOCAL ENVIRONMENTAL CONTROL REGULATIONS. HANDLE EMPTY CONTAINERS
W/CARE DUE TO PRODUCT RESIDUE & FLAMMABLE VAPORS. DON'T INCINERATE
CLOSED CONTAINERS.EPA CODE: D001, F003, F005. IGNITABLE.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:1400 BRU-TONE ALKYD SATIN ENAMEL WHITE
CAGE:EO376
CAGE:EO376
CAGE:85520
============= Composition/Information on Ingredients =============
Ingred Name:V M & P NAPHTHA, LIGROINE, MINERAL SPIRITS
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 25-35%
Other REC Limits:STEL 400 PPM
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 1-5%
OSHA PEL:20 MPPCF
ACGIH TLV:2 MG/CUM (RESP DUST)
Ingred Name:WEIGHT PER GALLON IN POUNDS: 10.6
RTECS #:9999999WG
Ingred Name:VOL ORGANIC CMPD: 3.435
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NOSE & THROAT IRRITATION.
EYES: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: PERMANENT BRAIN & NERVOUS SYSTEM
DAMAGE. MINERAL SPIRITS MAY CAUSE CENTRAL NERVOUS SYSTEM DEPRESSION
& MUCOUS MEMBRANE IRRITATION. SYMPTOMS INCLUDE DIZZINESS, HEADACHE,
INTOXICATION W/EUPH ORIA LEADING TO UNCONSCIOUSNESS.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/LUKE WARM WATER FOR 15 MINS. SKIN: WASH
W/COPIOUS AMOUNTS OF LUKE WARM WATER. INHALATION: REMOVE TO FRESH
AIR. RESTORE BREATHING IF REQUIRED. INGESTION: RINSE MOUTH
IMMEDIATELY. GIVE EXPO SED INDIVIDUAL 6 TO 8 OUNCES OF
LIQUID.(NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.)
DON'T INDUCE VOMITING UNLESS ADVISED BY A PHYSICIAN. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:104F
Lower Limits:0.9%
Upper Limits:7.0%
Extinguishing Media:NATIONAL FIRE PROTECTION ASSOCIATION CLASS B
EXTINGUISHER IS DESIGNED TO EXTINGUISH NFPA CLASS 1B FLAMMABLE
LIQUID FIRES
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. WATER MAY BE
USED TO COOL CONTAINERS TO PREVENT PRESSURE
BUILD-UP/IGNITION/EXPLOSION FROM HEAT. FOG NOZZLES ARE PREFERABLE.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. PRODUCT CONTAINER (EVEN EMPTY) MAY IGNITE
EXPLOSIVELY WHEN USING WELDING OR CUTTING TORCH.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN DISCHARGE. KEEP AWAY ALL SOURCES OF
IGNITION. VENTILATE SPILL. USE NON-SPARKING TOOLS FOR CLEANUP.
COVER W/INERT MATERIAL TO REDUCE FUMES. KEEP OUT OF
DRAINS/SEWERS/WATERWAYS. CONTACT FIRE AUT HORITIES. NOTIFY LOCAL
HEALTH/POLLUTIONAGENCIES.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS COOL/DRY. KEEP FROM
CHILDREN. DON'T SMOKE. CLOSED TIGHTLY AFTER USE. DON'T
CUT/PUNCTURE/WELD CONTAINER. AVOID SKIN/EYE CONTACT.
Other Precautions:INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING/INHALING CONTENTS MAY BE HARMFUL/FATAL. GROUND
CONTAINERS WHEN POURING/LIMIT FREE FALL TO FEW INCHES. AVOID
SPONTANEOUS COMBUSTION OF CONTAMINATED RAGS /EASILY IGNITABLE
ORGANIC MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:OPEN AREA: NIOSH/MSHA APPROVED MECHANICAL FILTER
RESPIRATOR. RESTRICTED: CHEMICAL-MECHANICAL FILTER. CONFINED: AIR
LINE TYPE RESPIRATOR/HOOD. WEAR PROPERLY FITTED RESPIRATOR UNLESS
AIR MONITORING DEMO NSTRATES VAPOR/MIST LEVELS BELOW LIMITS.
Ventilation:GENERAL DILUTION/LOCAL EXHAUST: IN VOLUME/PATTERN TO KEEP
TLV BELOW RECOMMENDED LIMIT/TO CONTROL VAPOR CONCENTRATIONS.
Other Protective Equipment:APRON
Work Hygienic Practices:REMOVE & WASH CONTAMINATED CLOTHES BEFORE
REUSE. WASH HANDS THOROUGHLY BEFORE EATING & AFTER USING WASHROOM.
Supplemental Safety and Health
EMPTY CONTAINERS MAY RETAIN HAZARDOUS PROPERTIES. THIS PRODUCT CONTAINS
PIGMENTS WHICH MAY BECOME A DUST NUISANCE WHEN REMOVED BY ABRASIVE
BLASTING, SANDING, OR GRINDING.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:300-388F
Vapor Pres:2
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN BU AC
Percent Volatiles by Volume:52.81
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Stability Condition to Avoid:EXTREME HEAT, SPARKS, OPEN FLAME, HOT
SURFACES, ELECTRICAL EQUIPMENT, & OTHER SOURCES OF IGNITION,
FREEZING
Hazardous Decomposition Products:CO, CO2, OXIDES OF NITROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T FLUSH TO SEWER/WATERSHED OR WATERWAY.
DISPOSE OF PRODUCT IN ACCORDANCE W/APPLICABLE LOCAL, COUNTY, STATE
& FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:FA3119
CAGE:JO764
CAGE:81831
CAGE:JO764
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR.AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UNC ONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:PREMIUM TICONIUM WIRE
CAGE:20750
CAGE:20750
CAGE:65024
============= Composition/Information on Ingredients =============
Ingred Name:NICKEL
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 10%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:COBALT
CAS:7440-48-4
RTECS #:GF8750000
Fraction by Wt: 51%
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.05 MG/M3 DUST
Ingred Name:CHROMIUM
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 20%
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TUNGSTEN
CAS:7440-33-7
RTECS #:YO7175000
Fraction by Wt: 15%
OSHA PEL:5 MG/M3;10 STEL
ACGIH TLV:5 MG/M3;10 STEL
Ingred Name:MANGANESE
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 1.5%
OSHA PEL:5 MG/M3 DUST, C
ACGIH TLV:5 MG/M3 DUST
Ingred Name:SUPDAT: 1991: GRP 2B. ANIMAL: PULM FIBROSIS (BLOOD EFTS)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SHORT-TERM OVEREXPOSURE TO WELDING
FUMES MAY RESULT IN DISCOMFORT SUCH AS DIZZ, NAUS/DRYNESS OR
IRRITATION OF NOSE, THROAT, OR EYES. SKIN CONTACT MAY BE THE CAUSE
OF DERMATITIS OR ALLERGIES.
Explanation of Carcinogenicity:CHROMIUM: IARC MONO, VOL 49, PG 49,
1990: GRP 1. NTP 6TH ANNUAL REPORT ON CARCINS, 1991: KNOWN TO BE
CARCIN. (SUPDAT)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:AGGRAVATION OF PREEXISTING
RESPIRATORY ALLERGIC CONDITIONS MAY OCCUR IN SOME WORKERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM WELDING AREA. ADMINISTER FIRST AID &
OBTAIN PROMPT MED ATTN. IF UNCON, ADMINISTER OXYGEN. IF NOT BRTHG,
BEGIN RESUSCITATION IMMED. INGEST: CALL MD IMMED . EYE: IMMED FLUSH
WIT H POTABLE WATER FOR A MINIMUM OF 15 MIN, SEEK ASSISTANCE FROM
MD . SKIN: FLUSH WITH COPIOUS AMOUNTS OF WATER. CALL MD .
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
================== Accidental Release Measures ==================
Spill Release Procedures:IN SOLID FORM THIS MATERAL POSES NO SPECIAL
CLEAN-UP PROBLEMS. REMOVE DUST BY VACUUMING OR WET SWEEPING TO
AVOID AIR CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED FUME/AIR SUPPLIED RESPIRATOR
WHEN WELDING.
Ventilation:LOCAL.
SHIELD WITH PROTECTIVE LENS .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLAN OF CARCIN: HUMAN/ANIMAL: LUNG CANCER, SKIN, ULCERS. NICKEL: IARC
MONO ON EVAL OF CARCIN RISK OF CHEMS TO MAN, VOL 49, PG 257, 1990:
GRP 2B. NTP 6TH ANNUAL REPORT ON CARCIN, 1991: ANTIC TO BE CA RCIN.
HUMAN: LUNGS, NASAL CAVITIES. COBALT: IARC MONO ON EVAL OF CARCIN
RISK OF CHEMS TO MAN, VOL 52, PG 363, (ING 6)
================== Physical/Chemical Properties ==================
Spec Gravity:7.9(H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:17,18,19 & 20 GUAGE DIAMETER WIRE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MINERAL ACIDS AND STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:VARIOUS ELEMENTAL, METAL OXIDES MAY BE
GENERATED FROM WELDING.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W STATE, LOCAL AND FEDERAL
REGULATIONS.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: GLASS WOOL, 763-265
Cage: FO436
=======================================================
Contractor Summary
=======================================================
Cage: 94174
Cage: FO436
Box: NK/
=======================================================
Ingredients
=======================================================
Cas: 65997-17-3
% Wt: 98-99
OSHA PEL: 15 MG/M3
ACGIH TLV: 10 MG/M3 DUST
------------------------------
% Wt: <1
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:PRODUCT IS A MECHANICAL IRRITANT TO SKIN, EYES &
UPPER RESPIRATORY SYSTEM. INHAL:IRRITATION OR SORENSS IN THROAT & NOSE.
IN EXTREME EXPOSURES SOME CONGESTION MAY OCCUR. INGEST:NOT HAZARDOUS WHEN
INGESTED. MAY CAUSE TEMPORARY IRRITATION TO GI TRACT. EYES:TEMPORARY
IRRITATION OR INFLAMMATION. (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:CHRONIC:WHEN COMBINING RESULTS OF
THREE INTERNATIONAL MORTALITY STUDIES OF FIBER GLASS MFG WORKERS, NO
STATISTICALLY SIGNIFICANT INCREASED RISKS FOR MALIGNANT OR NON-MALIGNANT
RESPIRATORY DIS EASE ARE FOUND. TARGET ORGANS:LUNGS, SKIN & EYES.
Medical Cond Aggravated By Exposure: AS W/ANY DUST, PRE-EXISTING UPPER
RESPIRATORY & LUNG DISEASES MAY BE AGGRAVATED.
First Aid: INGEST:CALL MD IMMEDIATELY (FP N). INHAL:REMOVE TO FRESH AIR. DRINK
WATER TO CLEAR THROAT & BLOW NOSE TO EVACUATE FIBERS. SKIN:WASH AFFECTED
AREAS GENTLY W/SOAP & WATER WATER. EYES:FLUSH W/COPIOUS QUA NTITIES OF
WATER FOR AT LEAST 15 MINUTES. IF IRRITATION PERSISTS, CONSULT MD.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: PICK UP PIECES. VACUUM CLEAN DUSTS. IF SWEEPING IS
NECESSARY USE A DUST SUPPRESSANT.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: WASTES ARE NOT HAZARDOUS AS DEFINED BY RCRA (40 CFR
PART 261). COMPLY W/FEDERAL, STATE & LOCAL REGULATIONS. METHOD OF
DISPOSAL - LANDFILL.
Handling And Storage Precautions: IRRITANT. KEEP MATERIAL DRY.
Other Precautions: ADEQUATE VENTILATION TO KEEP DUST LEVEL TO BELOW PEL/TLV/WEG
(WORKPLACE EXPOSURE GUIDELINE).
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NON-FLAMMABLE
Extinguishing Media: MEDIA SUITABLE FOR SURROUNDING FIRE (FP N).
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: <10 F/CC, USE NIOSH/MSHA APPROVED 3M 9900; <50
F/CC, USE NIOSH/MSHA APPROVED MSA ULTRA-TWIN W/H FILTER OR EQUIVALENTS.
Ventilation: USE SUFFICIENT NATURAL OR MECHANICAL VENTILATION TO KEEP DUST
LEVEL TO BELOW PEL/TLV/WEG.
Other Protective Equipment: WEAR LOOSE FITTING, LONG SLEEVED CLOTHING.
Work Hygienic Practices: WASH EXPOSED AREAS W/SOAP & WARM WATER AFTER HNDLG.
WASH WORK CLOTHES SEPARATELY FROM OTHER CLTHG. RINSE WASHER THORO.
Supplemental Safety and Health: MP:>1600F,>871C.
=======================================================
Physical/Chemical Properties
=======================================================
M.P/F.P Text: SUPP DATA
Spec Gravity: VARIES
Solubility in Water: NIL
Appearance and Odor: FIBROUS GLASS YARN; NO ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE IN DESIGNED USE.
Materials To Avoid: HYDROFLUORIC ACID.
Hazardous Decomposition Products: NONE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: GLASS WOOL, 763-265
Cage: FO436
Assigned IND: Y
Company Name: LECO CORPORATION
Street: 3000 LAKEVIEW AVENUE
PO Box: NK/
Zipcode: 49085
Label Required IND: Y
Date Of Label Review: 03/22/1994
Status Code: C
Label Date: 03/22/1994
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: IRRITANT. KEEP DRY. ACUTE:PRODUCT IS A MECHANICAL
IRRITANT TO SKIN, EYES & UPPER RESPIRATORY SYSTEM. INHAL:IRRITATION OR
SORENSS IN THROAT & NOSE. IN EXTREME EXPOSURES SOME CONGESTION MAY OCCUR.
INGES T:NOT HAZARDOUS WHEN INGESTED. MAY CAUSE TEMPORARY IRRITATION TO GI
TRACT. EYES:TEMPORARY IRRITATION OR INFLAMMATION. CHRONIC:NONE LISTED BY
MANUFACTURER.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:G-335C INDUSTRIAL X-RAY FIXER PART A
Kit Part:Y
CAGE:EO426
CAGE:59735
CAGE:EO426
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIUM THIOSULFATE
CAS:7783-18-8
RTECS #:XN6465000
Fraction by Wt: 50-55%
Ingred Name:SODIUM SULFITE
CAS:7757-83-7
RTECS #:WE2150000
Fraction by Wt: 1-5%
Other REC Limits:5 MG/CUM (DUST)
Ingred Name:ACETIC ACID (GLACIAL), ETHANOIC ACID *97-2*
CAS:64-19-7
RTECS #:AF1225000
Fraction by Wt: 1-5%
OSHA PEL:25 MG/CUM
ACGIH TLV:25 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MAY CAUSE IRRITATION.
INHALATION: MIST MAY CAUSE RESPIRATORY IRRITATION. INGESTION: MAY
CAUSE MUCOUS MEMBRANES/DIGESTIVE TRACT IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: IMMEDIATELY FLUSH W/PLENTY OF RUNNING WATER FOR 15
MINS. INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NON-COMBUSTIBLE
Extinguishing Media:ANY APPLICABLE TO PRIMARY CAUSE OF FIRE.
Fire Fighting Procedures:EVACUATE PERSONNEL TO A SAFE AREA. KEEP
PERSONNEL REMOVED & UPWIND OF FIRE. WEAR A SCBA.
Unusual Fire/Explosion Hazard:EMISSION OF TOXIC FUMES OF SULFUR DIOXIDE
IS POSSIBLE WHEN HEATED TO DECOMPOSITION.
================== Accidental Release Measures ==================
Spill Release Procedures:USE APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT
DURING CLEAN UP. DIKE. PREVENT LIQUID FROM ENTERING SEWERS,
WATERWAYS/LOW AREAS. SOAK UP W/SAWDUST, SAND, OIL DRY/OTHER
ABSORBENT MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN WELL VENTILATED AREA. KEEP
CONTAINER TIGHTLY CLOSED. DON'T STORE W/INCOMPATIBLE MATERIALS. USE
IN WELL VENTILATED AREA.
Other Precautions:DON'T STORE/CONSUME FOOD, DRINK/TOBACCO IN AREA WHERE
THEY MAY BECOME CONTAMINATED W/THIS MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NEEDED W/WORKING MIXTURES & NORMAL ROOM
VENTILATION.
Ventilation:ROOM VENTILATION IS SUFFICIENT.
Other Protective Equipment:APRONS
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Vapor Pres:AS WATER
Vapor Density:AS WATER
Spec Gravity:1.348
pH:5.2
Evaporation Rate & Reference:SAME AS WATER
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR & COLORLESS W/SLIGHT SULPHUR DIOXIDE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, STRONG ACIDS, OXIDIZERS.
Stability Condition to Avoid:HEAT.
Hazardous Decomposition Products:OXIDES OF SULFUR, CO2, CO, AMMONIA.
==================== Disposal Considerations ====================
Waste Disposal Methods:RECOVER NONUSABLE FREE LIQUID &/CONTAMINATED
WATER & DISPOSE OF IN APPROVED & PERMITTED TREATMENT SYSTEM. REMOVE
NONUSABLE SOLID MATERIAL &/CONTAMINATED SOIL & DISPOSE OF IN
APPROVED & PERMITTED LANDF ILL IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:443300 AUTO ARMOR INSIDE RUST PROTECTION, CLEAR
CAGE:ECPI1
CAGE:ECPI1
============= Composition/Information on Ingredients =============
Ingred Name:MEDIUM ALIPHATIC NAPHTHA (AROMATIC 100), PARAFFIN-NAPTHANES
MINERAL SPIRITS *94-2*
CAS:64742-88-7
Fraction by Wt: <70%
Other REC Limits:100 PPM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; PETROLEUM DISTILLATE,
HYDROTREATED ,(MINERAL SPIRITS)
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: <70%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN:
PROLONGED/REPEATED CONTACT CAN CAUSE MODERATE IRRITATION,
DERMATITIS. INHALATION: EXCESSIVE BREATHING OF VAPORS CAN CAUSE
NASAL, RESPIRATORY IRRITATION. INGESTION: GI IRRITATIO N.
ASPIRATION INTO THE LUNGS CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN
BE FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, REDNESS, TEARING, BLURRED VISION,
DEFATTING, DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, HEADACHE,
UNCONSCIOUSNESS, VOMITING, DIARRHEA.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MINS. SKIN: WASH W/SOAP &
WATER. INHALATION: REMOVE TO FRESH AIR. IF BREATHING HAS STOPPED,
GIVE CPR. KEEP PERSON WARM, QUIET. INGESTION: DON'T INDUCE
VOMITING. ASP IRATION HAZARD. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>100F
Lower Limits:0.7
Upper Limits:5
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:TREAT AS PETROLEUM FIRE.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:SHUT OFF IGNITION SOURCES. CONTAIN & KEEP FROM
ENTERING WATERWAYS/SEWERS. SMALL QUANTITIES MAY BE SOAKED UP ON
INERT ABSORBANTS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM IGNITION SOURCES. NEVER
USE A TORCH TO CUT/WELD ON/NEAR CONTAINER. EMPTY CONTAINERS CAN
CONTAIN EXPLOSIVE VAPORS.
Other Precautions:VAPORS ARE HEAVIER THAN AIR & WILL COLLECT IN LOW
AREAS. NEVER WEAR OIL SOAKED CLOTHING. AFFIX PROPER WARNING LABELS
ON CONTAINERS AS REQUIRED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV IS EXCEEDED, AN APPROVED ORGANIC
VAPOR-TYPE RESPIRATOR W/A FILTER FOR PARTICULATE MATTER IS
REQUIRED.
Ventilation:ENOUGH TO CONTROL VAPORS BELOW TLV.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING & WASH/DRY CLEAN
BEFORE REUSE. DISCARD OIL SOAKED SHOES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>300F
Vapor Pres:1.8
Spec Gravity:0.86 - 0.91
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER LIQUID W/WINTER GREEN ODOR
Percent Volatiles by Volume:76-80
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:FLAMES, SPARKS & HOT SURFACES
Hazardous Decomposition Products:CO, CO2, VARIOUS HYDROCARBON
DERIVATIVES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS. COMBUSTIBLE LIQUID UN1268.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: STINGRAY PAINT STRIPPER, 874B
Cage: 1FLY6
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 1FLY6
=======================================================
Item Description Information
=======================================================
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: MATERIAL MAY BE SEVERELY IRRITATING TO EYES, SKIN &
MUCOUS MEMBRANES. PROLONGED CONTACT WILL CAUSE BURNS. CORNEAL INJURY MAY BE
DELAYED. INHALATION OF HIGH CONCENTRATIONS CAN CAUSE SEVERE MUCOUS MEMBR ANE
IRRITATION & INFLAMMATION, PULMONARY EDEMA & SYSTEMATIC POISONING
W/SHOCK, COMA & SEIZURES. OVEREXPOSURES MAY CAUSE CARDIAC ARREST,
CEREBRAL EDEMA, SEIZURES, INTERSTITIAL LUNG DISEASE & RESPIRATOR Y
ARREST. VAPORS MAY BE IRRITATING TO EYES, NOSE & RESPIRATORY TRACT. MAY
BE SKIN ABSORBED CAUSING SYSTEMIC EFFECTS. HIGH EXPOSURE MAY CAUSE HEADACHE,
NAUSEA, VOMITING, DIARRHEA, CNS DEPRESSION, DROP IN BLOOD PRESSURE, (EFTS OF
OVEREXP)
Explanation Of Carcinogenicity: NTP:NO DATA: IARC:BASED ON A STUDY IN WHICH
DRINKING WATER CONTAMINATED W/HYDROGEN PEROXIDE WAS GIVEN TO EXPERIMENTAL
ANIMALS OVER A PROLONGED PERIOD OF TIME, THE IARC CONCLUDED THAT THERE IS
LIMITED EVIDENCE THAT HYDROGEN PEROXIDE IS CARCINOGENIC TO EXPERIMENTAL
ANIMALS. HYDROGEN PEROXIDE IS NOT CLASSIFIED AS TO ITS CARCINOGENICITY TO
HUMANS.
Signs And Symptions Of Overexposure: HLTH HAZ:VERTIGO & DEATH IN SEVERE
CASES DUE TO RESPIRATORY FAILURE. PROLONGED OR REPEATED SKIN CONTACT MAY
CAUSE DRYING OR ALLERGIC DERMATITIS. INGESTOIN MAY CAUSE SEVERE IRRITATION OF
THE GASTROINTE STINAL TRACT FOLLOWED BY NAUSEA, VOMITING, CRAMPS, DIARRHEA,
DROP IN BLOOD PRESSURE, CNS DEPRESSION & RESPIRATORY PARALYSIS.
Medical Cond Aggravated By Exposure: PULMONARY (LUNG) CONDITIONS.
First Aid: EYES: FLUSH THOROUGHLY WITH RUNNING WATER FOR AT LEAST 15 MINUTES,
INCLUDING UNDER EYELIDS. SEEK MEDICAL ATTENTION. SKIN: WASH EXPOSED SKIN
THOROUGHLY WITH SOAP & WATER. IF IRRITATION OR PAIN PERSISTS , SEEK
MEDICAL ATTENTION. INHALATION: MOVE TO FRESH AIR, MONITOR FOR RESPIRATORY
DISTRESS, SEEK MEDICAL ATTENTION. INGESTION: DO NOT INDUCE VOMITING UNLESS
ADVISED TO DO SO. CALL MD OR POISON CONTROL CENTER. SEEK MEDICAL ATTENTION
IMMEDIATELY.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: KEEP UNNECESSARY PEOPLE AWAY. ISOLATE HAZARD AREA
& DENY ENTRY. SPILL CONTROL PERSONNEL MUST WEAR NIOSH APPROVED FULL FACE
POSITIVE PRESSURE SCBA OR SUPPLIED AIR RESPIRATOR & IMPERVIOUS PERSONAL
PLACE INTO CONTAINERS FOR LATER DISPOSAL.
Waste Disposal Methods: DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS (FP N). IN ITS MANUFACTURED FORM THIS MATERIAL IS NON-REGULATED
BY RCRA. CONSULT STATE & LOCAL AUTHORITIES FOR DISPOSAL INFORMATION.
Handling And Storage Precautions: STORE MATL IN COOL AREA AWAY FROM DIRECT
SUNLIGHT & INCOMPATIBLE MATLS. PREVENT MATL FROM FREEZING; BUT IF FROZEN,
THAW AT ROOM TEMP. BENZYL ALCOHOL OXIDIZES SLOWLY IN AIR TO FORM
BENZALDEHYDE. FOR LO NG STORAGE, PARTIALLY FILLED DRUMS SHOULD BE BLANKED
W/NITROGEN. DO NOT SMOKE IN USE/HANDLING AREAS.
Other Precautions: ALL ELECTRICAL SERVICE IN USE OR STORAGE AREAS SHOULD HAVE
AN "EXPLOSION PROOF" DESIGN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point: >93.3C, 200.F
Extinguishing Media: USE WATER ONLY. CONTAINS HYDROGEN PEROXIDE, AN OXIDIZER.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). FLOOD WITH WATER.
Unusual Fire/Explosion Hazard: FLAMMABILITY CLASS: IIIB. CONTAINS 1-7% HYDROGEN
PEROXIDE. HYDROGEN PEROXIDE ITSELF REACTS W/WIDE RANGE OF MATLS &
ALTHOUGH NONCOMBUST, IT CAN RELS OXYGEN TO INCR COMBUST RATE OF OTHER MATLS.
LOW CONC S WILL NOT USUALLY IGNITE COMBUSTS IMMED, BUT SUBSEQUENT WATER EVAP
CAN CAUSE DELAYED DETONATION. CONT W/ORG (SUPP DATA)
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH APPROVED FULL FACEPIECE SUPPLIED AIR RESPIRATOR
IF EXPOSURE EXCEEDS PEL.
Ventilation: GENERAL VENTILATION. DILUTION OR LOCAL EXHAUST VENTILATION AS
REQUIRED TO MAINTAIN PEL.
(FP N).
Other Protective Equipment: EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA (FP N). IMPERVIOUS FULL PERSONAL PROTECTIVE CLOTHING INCLUDING BOOTS
SHOULD BE WORN AS NECESSARY TO PREVENT SKIN CONTACT.
Work Hygienic Practices: WASH THOROUGHLY WITH SOAP & WATER AFTER USING
MATERIAL.
Supplemental Safety and Health: EXPLO HAZ:LIQS/VAPS MAY CAUSE IMMED FIRE/EXPLO,
ESP IF HEATED, OR MAY RESULT IN DELAYED DETONATION. HAZ RATINGS: HEALTH - 2;
FIRE - 0; REACTIVITY - 1. PHYSICAL DATA: LIQUID DENSITY: HVR/WATER.
=======================================================
Physical/Chemical Properties
=======================================================
Boiling Point: >100.C, 212.F
B.P. Text: 212-306F
Vapor Pres: 3.454 MM HG (90F) & INGS
Vapor Density: HVR/AIR
Spec Gravity: 1.03
VOC Pounds/Gallon: 3.68
PH: 6.0-7.3
Evaporation Rate & Reference: 0.31 X N-BUTYL ACETATE
Appearance and Odor: THICK CREAMY YELLOW TO ORANGE EMULSION.
Percent Volatiles by Volume: 88.7
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEAT OR CONTAMINATION.
Materials To Avoid: CAUSTICS, ACIDS, ALKALI, CYANIDES, HEXAVALENT CHROMIUM
COMPOUNDS, NITRIC ACID, POTASSIUM PERMANGANATE, METAL CATALYSTS, OXIDIZING
AND REDUCING AGENTS AND FLAMMABLES.
Hazardous Decomposition Products: OXYGEN GAS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: WILL NOT OCCUR.
=======================================================
Toxicological Information
=======================================================
=======================================================
=======================================================
Transport Information: D.O.T. REQUIREMENTS: NON REGULATED BY D.O.T.
=======================================================
Regulatory Information
=======================================================
Federal Regulatory Information: ALL INGREDIENTS IN THIS PRODUCT ARE LISTED IN
THE T.S.C.A. INVENTORY.
=======================================================
Other Information
=======================================================
Other Information: THE AMERICAN INDUSTRIAL HYGIENE ASSOCIATION (AIHA) HAS REC
WORKPLACE ENVIRON EXPOS LIMIT (WEEL) FOR BENZYL ALCOHOL OF 10 PPM AS AN 8 HR
TWA. THIS REC LIM IS CURRENTLY NOT RECOGNIZED BY THE OCCUP SAFET Y & HLTH
ADMIN (OSHA),/AMERICAN CONFERENCE OF GOVT INDUS HYGIENISTS (ACGIH). THIS LIM
IS PROVIDED TO ENHANCE SAFETY AWARENESS WHEN HNDLG/USING THIS PROD. -
PROPRIETARY FORMULA - CONTAINS NO COMPONENTSTHAT ARE RPTD TO BE CARCIN TO
HUMANS BY ANY REFERENCE SOURCE INCL IARC, OSHA, NTP & EPA. NO OTHER HAZ
COMPONENTS AT 1% OR MORE LISTED IN 29 CFR 1910, SUBPART Z. US PATENT
#5,454,985 & #5,721,204 & O THER U.S. & FOREIGN PATENTS PENDING.
=======================================================
HAZCOM Label
=======================================================
Product ID: STINGRAY PAINT STRIPPER, 874B
Cage: 1FLY6
Company Name: GAGE PRODUCTS COMPANY
Street: 821 WANDA AVENUE
Zipcode: 48220
Label Required IND: Y
Date Of Label Review: 04/06/1999
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Severe
Contact Hazard: Severe
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE:SEV IRRIT TO EYES, SKIN & MUC MEMB.
PRLNGD CONTACT WILL CAUSE BURNS. CORNEAL INJURY MAY BE DELAYED. INHAL: SEV
MEMB IRRIT, INFLAMM, PULM EDEMA, & SYSTEMIC POISONING W/SHOCK, COMA &
SEIZU RES. POSSIBLE CARDIAC ARREST, CEREBRAL EDEMAL, SEIZURES, INTERSTITIAL
LUNG DISEASE & RESP ARREST. MAY BE ABSORB THROUGH SKIN CAUSING SYSTEMIC
EFTS. POSSIBLE HEADACHE, NAUSEA, VOMIT, DIARR, CNS DEP RESS, DROP IN BLOOD
PRESSURE, VERTIGO, DEATH DUE TO RESP FAILURE. PRLNG/RPTD SKIN CONTACT MAY
CAUSE DRYING/ALLERGIC DERM. INGEST: SEV IRRIT, NAUS, VOMIT, CRAMPS, DIARR,
DROP BLOOD PRESS, CNS DEPRESS , RESP PARALYSIS. CHRONIC: POSSIBLE
CARCINOGEN.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ODORLESS MINERAL SPIRITS, 80195
Preparer's Name:J C WILLET
CAGE:SHELO
CAGE:SHELO
CAGE:54527
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA, HEAVY ALKYLATE (A COMPLEX MIXTURE OF PREDOMINATELY
BRANCHED CHAIN, SATURATED C9-C12 (ING 2)
CAS:64741-65-7
Fraction by Wt: 100%
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:ING 1: HYDROCARBONS).
RTECS #:9999999ZZ
Ingred Name:SUPDAT: 2U-GLOBULIN IN RENAL TUBULAR CELLS & MAY NOT BE
RELEVANT FOR HUMANS WHO DO NOT HAVE THIS PROTEIN. IN A (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: 13 WEEK INHAL STUDY MALE RATS EXPOS TO VAPS OF
SIMILAR SOLV SHOWED EVID OF KIDNEY EFTS ALONG W/LOW GRADE (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: ANEMIA. IN RESPONSE TO TSCA TEST RULE, SEVERAL
STUDIES OF CMPD SIMILAR TO THIS PROD HAVE BEEN COMPLETED. (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: MUTAGENICITY STUDIES & RAT INHAL NEUROTOXICITY STUDY
WERE NEGATIVE. IN MOUSE DEVELOPMENTAL EFTS STUDY, (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: REDUCED FETAL BODY WT WAS SEEN BUT NO
TERATOGENICITY. A RAT REPROD EFTS STUDY DEMONSTRATED TOX BUT LITTLE
(ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: EFT ON REPRODUCTIVE PARAMETERS.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: SPONT. KEEP HEAD BELOW HIPS TO PVNT ASPIR
OF LIQ INTO LUNGS. GET MED ATTN. NOTE TO PHYS: IF (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: >2.0 ML PER KG HAS BEEN INGESTED & VOMIT HAS NOT
OCCURED, EMESIS SHOULD BE INDUCED W/SUPERVISION. KEEP (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: VICTIM'S HEAD BELOW HIPS TO PVNT ASPIR. IF SYMPS
SUCH AS LOSS OF GAG REFLEX, CONVLS/UNCON OCCUR BEFORE (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: EMESIS, GASTRIC LAVAGE USING CUFFED ENDOTRACHEAL
TUBE SHOULD BE CONSIDERED.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: ABSORB SUCH AS CLAY, SAND/OTHER SUITABLE MATL:
PLACE IN NON-LEAKING CNTNRS & SEAL TIGHTLY FOR PROPER(ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: DISP. FLUSH AREA W/WATER TO REMOVE TRACE RESIDUE;
DISPOSE OF FLUSH SOLN. SM SPILLS: TAKE UP W/ABSORB (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: MATL & PLACE IN NON-LEAKING CONTAINERS FOR PROPER
DISPOSAL.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: W/ADEQ VENT. CNTNRS, EVEN THOST THAT HAVE BEEN
EMPTIED, CAN CNTN EXPLO VAPS. DO NOT CUT, DRILL, (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17: GRIND, WELD/PERFORM SIMILAR OPERATIONS ON/NEAR
CNTNRS. DO NOT PRESSURIZE DRUM CNTNRS TO EMPTY THEM. (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: STATIC ELEC MAY ACCUM & CREATE FIRE HAZARD. GROUND
FIXED EQUIP. BOND & GROUND TRANSFER CNTNRS & EQUIP.
RTECS #:9999999ZZ
Ingred Name:HYGIENE PRACT: CLOTHING BEFORE REUSE. AIR-DRY CONTAMD CLTHG
IN WELL VENTILATED AREA BEFORE LAUNDERING.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL,RAT) >25 ML/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: LIQUID IS EXPECTED TO BE
NONIRRITATING TO PRACTICALLY NONIRRITATING TO EYES. SKIN: LIQUID IS
EXPECTED TO BE SLIGHTLY TO MODERATELY IRRITATING TO SKIN.
PRLNGD/RPTD LIQ CONT CAN RSLT IN DEFA T & DRYING OF SKIN WHICH MAY
RSLT IN SKIN IRRIT & DERM. INHAL: HIGH VAP CONCS MAY RSLT IN CNS
DEPRESS. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: INGEST: MAY RSLT IN VOMIT; ASPIR
(BRTHG) OF VOMITUS INTO LUNGS MUST BE AVOIDED AS EVEN SM QTYS MAY
RSLT IN ASPIR PNEUM. SIGNS & SYMPS: MILD IRRIT. EARLY TO MOD CNS
DEPRESS MAY BE EVID BY GID D, HDCH, DIZZ & NAUS: IN EXTREME
CASES,UNCON & DEATH MAY OCCUR. SUPP HLTH INFO: PRLNGD & RPTD EXPOS
TO (SUPDAT)
Medical Cond Aggravated by Exposure:PREEXISTING EYE AND SKIN DISORDERS
MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/WATER FOR @ LST 15 MINS. IF IRRIT OCCURS, GET
MED ATTN. SKIN: REMOVE CONTAMD CLTHG/SHOES & WIPE EXCESS FROM SKIN.
FLUSH W/WATER. FOLLOW BY WASHING W/SOAP & WATER. IF IRRIT OCCURS,
GET MED ATTN. DO NOT REUSE CLTHG UNTIL CLEANED. INHAL: REMOVE TO
FRESH AIR & PROVIDE OXYG IF BRTHG IS DFCLT. GIVE ARTF RESP IF NOT
BRTHG. GET MED ATTN. INGEST: DO NO INDUCE VOMIT. IF VOMIT OCCURS
(ING 10)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:125F,52C
Lower Limits:1%
Upper Limits:7%
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEM/CO*2. DO NOT USE
DIRECT STREAM OF WATER. PROD WILL FLOAT & CAN BE REIGNITED ON
(SUPDAT)
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . CAUTION. COMBUSTIBLE. COOL FIRE EXPOSED CONTAINERS WITH
WATER.
Unusual Fire/Explosion Hazard:CNTNRS EXPOS TO INTENSE HEAT FROM FIRE
SHOULD BE COOLED W/WATER TO PVNT VAP PRESS BUILDUP WHICH COULD RSLT
IN CNTNR RUPTURE. CNTNR AREAS EXPOS TO DIRECT(SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:CAUTION. COMBUST. LG SPILLS: ELIM POTNTL
SOURCES OF IGNIT. WEAR APPROP NIOSH APPRVD RESP & OTHER PROT CLTHG.
SHUT OFF SOURCE OF LEAK ONLY IF SAFE TO DO SO. DIKE & CNTN. REMOVE
W/VACUUM TRUCKS/PUMP TO STORAGE/SALV VESSELS. SOAK UP RESIDUE W/
(ING 14)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP LIQUID & VAPOR AWAY FROM HEAT,
SPARKS & FLAME. SURFACES THAT ARE SUFFICIENTLY HOT MAY IGNITE EVEN
LIQUID PROD IN ABSENCE OF SPARKS OR FLAME.
Other Precautions:EXTING PILOT LIGHTS, CIGARETTES & TURN OFF OTHER
SOURCES OF IGNIT PRIOR TO USE & UNTIL ALL VAPS ARE GONE. VAPS MAY
ACCUM & TRAVEL TO IGNIT SOURCES DISTANT FROM HNDLG SITE; FLASHFIRE
CAN RSLT. KEEP CNT NRS CLSD WHEN NOT IN USE. USE (ING 17)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID PRLNGD/RPTD BRTHG OF VAPS. USE NIOSH
APPRVD RESP AS REQD TO PVNT OVEREXP. IN ACCORD WITH 29 CFR
1910.134, USE EITHER NIOSH APPRVD ATMOSPHERE-SUPPLYING
RESP/AIR-PURIFYING RESP FOR ORGANIC VAPORS.
Ventilation:USE VENT AS REQD TO CTL VAP CONCS. AIR-DRY CONTAMD CLTHG IN
WELL VENTILATED AREA. THEN LAUNDER BEFORE REUSING.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:WASH W/SOAP & WATER BEFORE EATING, DRINKING,
SMKNG, APPLYING COSMETICS/USING TOILET FACILITIES. LAUNDER CONTAMD
(ING 20)
Supplemental Safety and Health
EXTING MEDIA: SURF OF WATER. EXPLO HAZ: FLAME CONT SHOULD BE COOLED
W/LG QTYS OF WATER AS NEEDED TO PVNT WEAKENING OF CNTNR STRUCTURE.
EFTS OF OVEREXP: ISOPARAFFINIC HYDROCARBS HAVE RSLTD IN RENAL TUB
ULAR DMG IN KIDNEYS OF MALE RATS. THIS EFT APPEARS TO BE RSLT OF
ACCUM OF MALE RAT-SPECIFIC PROTEIN, ALPHA (ING 4)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>355F,>179C
Vapor Pres:1.9 @ 100F
Vapor Density:5.3
Spec Gravity:0.759 (H*2O=1)
VOC Grams/Liter:8.24
Evaporation Rate & Reference:<0.1 (N-BUTYL ACETATE =1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT COLORED LIQUID. HYDROCARBON ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID HEAT, FLAME AND CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID HEAT, FLAME AND CONTACT WITH STRONG
OXIDIZING AGENTS.
Hazardous Decomposition Products:CARBON MONOXIDE AND UNIDENTIFIED
ORGANIC COMPOUNDS MAY BE FORMED DURING COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS .
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:PPS-300 2-BROMOPROPANOIC ACID SOLUTION
CAGE:0MU35
CAGE:0MU35
============= Composition/Information on Ingredients =============
Ingred Name:METHYL TERT BUTYL ETHER (MTBE), 2-METHOXY-2-METHYL PROPANE
* 95-1 *
CAS:1634-04-4
RTECS #:KN5250000
Fraction by Wt: 99.86%
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:2-BROMOPROPANOIC ACID
CAS:598-72-1
Fraction by Wt: 0.132%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TOXIC; IRRITANT. CORROSIVE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:TOXIC; IRRITANT. CORROSIVE
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/COPIOUS AMOUNTS OF WATER. INHALATION:
REMOVE TO FRESH AIR. GIVE OXYGEN IF NEEDED. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:COMBUSTIBLE
Extinguishing Media:CO2, DRY CHEMICAL POWDER/WATER SPRAY
Unusual Fire/Explosion Hazard:COMBUSTIBLE
================== Accidental Release Measures ==================
Spill Release Procedures:A LEAKING BOTTLE MAY BE PLACED IN A PLASTIC
BAG & NORMAL DISPOSAL PROCEDURES FOLLOWED. LIQUID SAMPLES MAY BE
ABSORBED ON VERMICULITE/SAND.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP TIGHTLY CLOSED, & STORE IN A
COOL, DRY PLACE.
Other Precautions:ALL CHEMICALS SHOULD BE CONSIDERED HAZARDOUS - DIRECT
PHYSICAL CONTACT SHOULD BE AVOIDED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE APPROPRIATE OSHA/MSHA APPROVED SAFETY
EQUIPMENT.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING, LAB COAT,
RUBBER APRON.
Supplemental Safety and Health
THIS MATERIAL SHOULD ONLY BE USED BY THOSE PERSONS TRAINED IN THE SAFE
HANDLING OF HAZARDOUS CHEMICALS.
================== Physical/Chemical Properties ==================
Appearance and Odor:LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED W/AN
AFTERBURNER & SCRUBBER, IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:METHYL ETHYL KETONE
CAGE:GREA1
CAGE:GREA1
CAGE:2P121
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATING TO SKIN, EYES, AND MUCOUS
MEMBRANES. PROLONGED INHALATION OR INGESTION MAY CAUSE HEADACHE,
DROWSINESS, AND NAUSEA.
Explanation of Carcinogenicity:MANUFACTURER STATES "THIS PRODUCT IS NOT
LISTED AS A SUSPECTED OR COMFIRMED CARCINOGEN BY OSHA, NTP, OR
IARC.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATERFOR 15 MINUTES. GET MEDICAL ATTENTION
IF IRRITATION PERSISTS. SKIN: REMOVE CONTAMINATED CLOTHING. WASH
AREA WITH SOAP AND WATER. INHALATION: REMOVE TO FRESH AIR. GIVE CPR
IF NOT BREATHING. GIVE OXYGEN IF BREATHING DIFFICULT. GET MEDICAL
ATTENTION. INGESTION: DO NOT INDUCE VOMITING. SEEK MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:21.0F,-6.1C
Lower Limits:1.8
Upper Limits:10.1
Extinguishing Media:WATER, CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND SELF-CONTAINED
BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:VAPORS MAY CONCENTRATE IN CONFINED AREAS
AND FORM EXPLOSIVE MIXTURES.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. CONTAIN AND
COLLECT OR ABSORB. SMALL SPILLS MAY BE FLUSHED TO SEWER WITH LARGE
AMOUNTS OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
STORE IN A COOL, DRY PLACE.
Other Precautions:DANGER-FLAMMABLE. AVOID HEAT AND SOURCE OF IGNITION.
USE ONLY WITH ADEQUATE VENTILATION. AVOID CONTACT WITH SKIN AND
EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH-APPROVED RESPIRATOR WITH ORGANIC VAPOR
CARTRIDGE OR SELF-CONTAINED BREATHING APPARATUS.
Ventilation:LOCAL EXHAUST VENTILATION WHERE VAPOR CONCENTRATIONS ARE
HIGH. MECHANICAL VENTILATION MAY NOT BE SUFFICIENT.
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER, RUBBER
BOOTS AND APRON.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSING.
Supplemental Safety and Health
VAPORS OF THIS PRODUCT MAY BE IGNITED BY STATIC SPARKS. USE PROPER
BONDING AND GROUNDING DURING LIQUID TRANSFER. EXPLOSION-PROOF
EQUIPMENT WHERE VAPOR CONCENTRATION ARE HIGH.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:175.3F,79C
Vapor Pres:71
Vapor Density:2.4
Spec Gravity:0.8060 @ 20C
Evaporation Rate & Reference:6.31 (BUTYL ACETATE=1)
Solubility in Water:APPRECIABLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND BASES, STRONG OXIDIZERS, HALOGEN COMPOUNDS.
Stability Condition to Avoid:HEAT, SOURCES OF IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:GD-500
CAGE:55208
CAGE:55208
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTOXYETHANOL
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 5.0%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
Ingred Name:MONO PHENOL POLYETHYLENE GLYCOL
Fraction by Wt: 9.0%
Ingred Name:SODIUM DODECYL BENZENE SULFONATE
CAS:25155-30-0
RTECS #:DB6825000
Fraction by Wt: 7.0%
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:WILL IRRITATE EYES. WILL DEFAT SKIN ON
PROLONGED CONTACT.
Medical Cond Aggravated by Exposure:ANY CONDITIONS AFFECTING THE SAME
ORGANS AS THOSE AFFECTED BY OVEREXPOSURE.
======================= First Aid Measures =======================
First Aid:FLUSH WITH WATER. APPLY SOOTHING LOTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:EXTINGUISH WITH AGENT SUITABLE FOR SURROUNDING FIRE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES,VENTILATE AREA
WELL.ABSORB WITH VERMICULITE OR OTHER MATERIALS, SUCH AS
SAWDUST,RAGS,PAPER & PLACE IN CLOSED CONTAINER. USE NON SPARKING
TOOLS. WEAR PROPER PROTECTIVE EQUIPMENT DURING CLEAN UP.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY WELL VENTED LOW FIRE
RISK AREA. PROTECT FROM HEAT,SHOCK,FRICTION. KEEP CONTAINERS
CLOSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED.
Ventilation:NORMAL ROOM VENTILATION.
Other Protective Equipment:NORMAL WORK CLOTHING COVERING ARMS & LEGS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:215F, 102C
Vapor Pres:20
Vapor Density:1
Spec Gravity:1.05
Evaporation Rate & Reference:1 (WATER = 1)
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR THIN LIQUID, MILD ODOR.
Percent Volatiles by Volume:80
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Hazardous Decomposition Products:NONE NOTED,BUT EXPECT CO, CO*2, H*2O.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:VORTEX, ORGANIC SOLVENT DEGREASER
CAGE:8S927
CAGE:0WU71
CAGE:8S927
============= Composition/Information on Ingredients =============
Ingred Name:D-LIMONENE
CAS:5989-27-5
Fraction by Wt: >90%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION-MAY CAUSE GASTROINTESTINAL
IRRITATION. INHALATION-ASPIRATION INTO LUNGS MAY CAUSE INJURY.
EYES-EXPOSURE TO HIGH CONCENTRATION OF VAPORS MAY CAUSE SLIGHT
TEMPORARY IRRITATION. SKIN-PROLONGED OR REPEATED EXPOSURE MAY
CAUSE SKIN IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INGESTION-MAY CAUSE NAUSEA, VOMITING.
INHALATION-EXCESSIVE INHALATION OF VAPORS MAY CAUSE DIZZINESS OR
HEADACHE. SKIN-PROLONGED OR REPEATED EXPOSURE MAY CAUSE RASHES OR
DEFATTING. REPEATED LONG-TERM C ONTACT MAY CAUSE EXCESSIVE DRYING
OR FLAKING OF SKIN.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGESTION-DO NOT INDUCE VOMITING. GIVE WATER OR MILK. CALL A
PHYSICIAN IMMEDIATELY. INHALATION-REMOVE TO FRESH AIR. IF BREATHING
IS DIFFICULT, GIVE OXYGEN, CALL PHYSICIAN. EYES-IRRIGATE
IMMEDIATELY WI TH WATER FOR AT LEAST 15 MINUTES. CALL A PHYSICIAN.
SKIN-WASH OFF IN FLOWING WATER OR SHOWER USING SOAP AND WATER.
REMOVE CONTAMINATED CLOTHING AND WASH BEFORE RESUE.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:119F,48C
Extinguishing Media:REGULAR FOAM, CARBON DIOXIDE OR DRY CHEMICALS.
Fire Fighting Procedures:DO NOT USE WATER. WEAR SELF-CONTAINED NIOSH
APPROVED, BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NON-TOXIC AND TOXIC FUMES MAY FORM UPON
COMBUSTION.
================== Accidental Release Measures ==================
Spill Release Procedures:LARGE SPILL: REMOVE ALL SOURCES OF IGNITION.
PERSONS NOT WEARING PROTECTIVE EQUIPMENT SHOULD BE EXCUSED FROM
AREA. DIKE AREA OF SPILL TO PREVENT SPREADING, PUMP INTO A STORAGE
OR RECYCLING TANK/DRUM. PREVENT RUNOFF TO SEWERS, STREAMS OR
WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS AWAY FROM
HEAT OR SOURCES OF IGNITION AND OXIDIZING MATERIAL. KEEP OUT OF
REACH OF CHILDREN.
Other Precautions:TREAT AS COMBUSTIBLE LIQUID. AS WITH ANY COMBUSTIBLE
OIL OR SOLVENT, ALL RAGS USED IN CONJUNCTION WITH THIS PRODUCT MUST
BE PLACED IN AMETAL SEALABLE CONTAINER AFTER USE TO AVOID THE
POSSIBLITY OF SPO NTANEOUS COMBUSTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WITH NORMAL USE.
Ventilation:NONE REQUIRED.
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:USE WITH ADEQUATE VENTILATION. WASH HNADS AFTER
USE.
Supplemental Safety and Health
ALWAYS KEEP CONTAINER CLOSED. OTHER PRECAUTIONS: READ LABEL BEFORE USE.
AVOID EXCESSIVE CONTACT WITH FUMES OR LIQUID.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:330F,166C
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:<1 MMHG
Vapor Density:>1 AIR=1
Spec Gravity:0.844
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:EMULSIFIABLE
Appearance and Odor:CLEAR, COLORLESS LIQUID WITH MILD CITRUS ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT.
Hazardous Decomposition Products:OXIDES OF CARBON MAY BE FORMED UPON
COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:TREAT AS SIMPLE OIL WASTE. INCINERATE OR
LANDFILL IN MANNER CONFORMING TO STATE, FEDERAL AND LOCAL REGS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:350B THINNER
CAGE:2H740
CAGE:2H740
============= Composition/Information on Ingredients =============
Ingred Name:PARAFFINS(INCLUDING NAPHTHENES)
Fraction by Wt: 98%
Ingred Name:C*8+(EIGHT CARBONS PLUS)
Fraction by Wt: 2%
Ingred Name:BENZENE (SARA III)
CAS:71-43-2
RTECS #:CY1400000
OSHA PEL:1PPM/5STEL;1910.1028
ACGIH TLV:10 PPM; A2; 9192
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
Effects of Overexposure:EYE: MINOR IRRIT. SKIN: IRRIT,CRACKD/DRY FROM
DEFATTING. INH: CNS DEPRESSN. INGEST:VOMIT,PNEUMONITIS
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/ WATER FOR 15 MIN. SEE DOCTOR IF IRRIT
PERSISTS.SKIN: WASH W/ SOAP & WATER. REMOVE & WASH CONTAMINATED
CLOTHES BEFORE REUSE. INHAL: REMOVE TO FRESH AIR,APPLY ARTIF RESP
IF NEC,CALL DOCTORIMMED. INGEST: DO NOT INDUCE VOMIT,SEESUPP DATA
===================== Fire Fighting Measures =====================
Flash Point:105F;41C; TCC
Lower Limits:1
Upper Limits:6
Extinguishing Media:CO*2,DRY CHEM,FOAM,WATER SPRAY
Fire Fighting Procedures:WEAR PROPER PROTECT EQUIP-INCLUDING SELF-CONT
BRTH APPAR
Unusual Fire/Explosion Hazard:NORMAL PRODUCTS OF COMBUSTION & OXYGEN
DEFICIENCY SUCH AS CO*2,WATER VAPOR & CARBON MONOXIDE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB LARGE SPILLS W/ ABSORBENT
CLAY,DIATOMACEOUS EARTH,OR OTHER SUITABLE MATEIAL AS SOON AS
POSSIBLE. A FIRE OR VAPOR HAZARD MAY EXIST SINCE THESE CLEANUP
MATERIALS WILL ONLY ABSORB LIQ;THEY WILL NO T ABSORB VAPOR. OBSERVE
ALL PRECAUTIONSOF PRODUCT
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE NEAR FLAME,SPARKS OR HOT
SURFACES. USE ONLY IN WELL VENTED AREA. KEEP CONTAINER CLOSED. DO
NOT WELD,DRILL OR HEAT CONTAINER.
Other Precautions:REPLACE CAP OR BUNG. EMPTIED CONTAINER STILL CONTAINS
HAZARDOUS OR EXPLOSIVE VAPOR OR LIQUID. DO NOT USE PRESSURE TO
EMPTY DRUM OR EXPLOSION MAY RESULT
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD ORGANIC VAPOR CART OR
AIR-SUPPLIED RESP (MFR)
Ventilation:ADEQUATE VENT TO KEEP CONC BELOW TLV
Other Protective Equipment:IMPERVIOUS PROTECTIVE CLOTHING.
Supplemental Safety and Health
FLASH PT: 116F,47C;TOC. VISCOSITY: 1.072CST @ 100F. MOLECULAR WT:
142(AVG). FIRST AID: INGEST-VOMITING CAN RESULT IN ASPIRATION WHICH
CAN CAUSE PNEUMONITIS,CALL MD IMMEDIATELY. SIZE: 55 GAL
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:314-387F
Vapor Pres:5
Vapor Density:4.9
Spec Gravity:0.79
Evaporation Rate & Reference:0.13 (BUAC=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORLESS LIQUID
Percent Volatiles by Volume:99
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIAL
Hazardous Decomposition Products:NORMAL COMBUST: CO*2,WATER
VAPOR;INCOMPLETE COMBUST: CO
==================== Disposal Considerations ====================
Waste Disposal Methods:MFR RECOMMENDS PLACING CONTAMINATED MATERIALS IN
DISPOSAL CONTAINERS & BURYING IN AN APPROVED DUMPING AREA. DISPOSAL
METHOD MUST BE IAW FED, STATE & LOCAL CODES.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:1,2,4-TRIMETHYLBENZENE (PSEUDOCUMENE)
CAGE:0ERJ7
CAGE:51851
CAGE:0ERJ7
============= Composition/Information on Ingredients =============
Ingred Name:BENZENE, 1,2,4-TRIMETHYL-; (1,2,4-TRIMETHYLBENZENE) (SARA
313)
CAS:95-63-6
RTECS #:DC3325000
Fraction by Wt: 100%
OSHA PEL:25 PPM
ACGIH TLV:25 PPM
Ingred Name:SUPDAT:IMPAIRED GAG REFLEX, IPECAC EMESIS CAN BE DONE. WHEN
VOMIT BEGINS, KEEP HEAD LOWER THAN HIPS TO PREVENT (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2:ASPIR. AFTER VOMIT STOPS, GIVE 30-60 MLS OF FLEET'S
PHOSPHO-SODA DILUTED 1:4 IN WATER. MAINTAIN AIRWAY, (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:BLOOD PRESS & RESP. TREATMENT MUST BE ADMINISTERED BY
QUALIFIED MED PERS. GET MED ATTN IMMED. ANTIDOTE:NO (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:SPECIFIC ANTIDOTE. TREAT SYMPTOMATICALLY &
SUPPORTIVELY.
RTECS #:9999999ZZ
Ingred Name:OTHER PROT EQUIP:THAT EYES MAY BE EXPOS TO THIS SUBSTANCE,
AN EYE WASH FOUNTAIN & QUICK DRENCH SHOWER SHOULD BE (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:W/IN THE IMMEDIATE WORK AREA.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION, SKIN & EYE IRRITANT.
NARCOTIC. MODERATELY TOXIC BY INHALATION & INGESTION. INHAL:MAY
CAUSE MUCOUS MEMBRANE IRRITATION, CNS DEPRESSION & CHEMICAL
PNEUMONITIS. SKIN:SYSTEMIC TOXICITY D UE TO ABSORPTION IS NOT
PROBABLE. EYE:MAY CAUSE IRRITATION. INGEST:NO SYMPTOMS WERE FOUND.
CHRONIC: (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:INHAL:ASTHMATIC BRONCH, HDCH, FATG,
TENSION, ANXIETY, NERVOUSNESS & DROW OBSERVED IN EXPOS WORKERS.
DEPRESSED WT GAIN, PROGRESSIVELY INCR LYMPHOPENIA & NEUTROPHILIA &
A MARKED CNS DEPRESS OBS ERVED IN ANIMALS. SKIN:MAY CAUSE
DERMATITIS. EYE:MAY CAUSE CONJUNCTIVITIS. INGEST:NO DATA AVAILABLE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOS AREA TO FRESH AIR IMMED. IF BRTHG HAS
STOPPED, PERFORM ARTF RESP. KEEP PERS WARM & AT REST. TREAT
SYMPTOMATICALLY & SUPPORTIVELY. GET MED ATTN IMMED. SKIN:REMOVE
CONTAM CLTHG & SHOES IMMED. WASH AFFECTED AREA W/SOAPOR MILD
DETERGENT & LG AMTS OF WATER UNTIL NO EVID OF CHEM REMAINS (APPROX
15-20 MINS). GET MED ATTN IMMED. EYES:WASH IMMED W/LG AMTS OF
WATER/NORMAL (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:112F,44C
Lower Limits:0.9%
Upper Limits:6.4%
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, HALON, WATER SPRAY OR
ALCOHOL FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:MOD FIRE HAZ WHEN EXPOSED TO HEAT/FLAME.
VAPS ARE HVR/AIR & MAY TRAVEL CONSIDERABLE DIST TO SOURCE OF IGNIT
& FLASH BACK. VAP-AIR MIXTS ARE EXPLO ABOVE (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:SM SPILLS:SHUT OFF IGNIT SOURCES. STOP LEAK IF
YOU CAN DO IT W/OUT RISK. USE WATER SPRAY TO REDUCE VAPS. TAKE UP
W/SAND OR OTHER ABSORB MATL & PLACE INTO CNTNRS FOR LATER DISP. NO
SMOKING, FLAMES/FLAR ES IN HAZ AREA. ISOLATE HAZ AREA & DENYENTRY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT W/HEAT, SPARKS, FLAMES
OR OTHER SOURCES OF IGNITION. VAPORS MAY BE EXPLOSIVE & POISONOUS;
DO NOT ALLOW UNNECESSARY PERSONNEL IN AREA.
Other Precautions:DO NOT OVERHEAT CONTAINERS; CONTAINERS MAY VIOLENTLY
RUPTURE & TRAVEL A CONSIDERABLE DISTANCE IN HEAT OF FIRE. STORE
I/A/W 29 CFR 1910.106 & AWAY FROM INCOMPATIBLE SUBSTANCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:PROVIDE LOCAL EXHAUST VENTILATION &/OR GENERAL DILUTION
VENTILATION TO MEET PUBLISHED EXPOSURE LIMITS.
Other Protective Equipment:WEAR APPROP PROT (IMPERVIOUS) EQUIP TO PVNT
RPTD/PRLNG SKIN CONT W/THIS SUBSTANCE. WHERE THERE IS ANY
POSSIBLITY (ING 6)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ:FLASH POINT. FIRST AID PROC:SALINE, OCCAS LIFTING UPPER &
LOWER LIDS, UNTIL NO EVID OF CHEM REMAINS (AT LST 15 MINS). GET MED
ATTN IMMED. INGEST:EXTREME CARE MUST BE USED TO PVNT ASPIR. USE
GASTRIC LAVAGE W/ACTIVATED CHARCOAL & CUFFED ENDOTRACHEAL TUBE W/IN
15 MINS. IN ABSENCE OF DEPRESS/CONVLS/ (ING 2)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:336F,169C
Melt/Freeze Pt:M.P/F.P Text:-47F,-44C
Vapor Pres:1.7 @ 20C
Appearance and Odor:COLORLESS LIQUID W/AROMATIC ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS: FIRE & EXPLOSION HAZARD.
Stability Condition to Avoid:STABLE UNDER NORMAL TEMPERATURES &
PRESSURES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE TOXIC OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . DISPOSAL MUST BE I/A/W STANDARDS APPLICABLE TO
GENERATORS OF HAZARDOUS WASTE, 40 CFR 262. EPA HAZ WASTE NUMBER
D001.
| 1 |
gloves_mandatory
|
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.