text
stringlengths 542
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:2-DEOXY-D-RIBOSE,99%,15328-0250
CAGE:ACR0S
CAGE:ACR0S
============= Composition/Information on Ingredients =============
Ingred Name:2-DEOXY-D-RIBOSE
CAS:533-67-5
RTECS #:SB7230000
= Wt:99.
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT AVAILABLE.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NOT AVAILABLE.
Explanation of Carcinogenicity:2-DEOXY-D-RIBOSE - NOT LISTED BY ACGIH,
IARC, NIOSH, NTP OR OSHA.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES, OCCASIONALLY LIFTING UPPER AND LOWER LIDS. SKIN: FLUSH
WITH PLENTY OF SOAP AND WATER FOR AT LEAST 15 MINUTES WHILE
REMOVING CONTAM INATED CLOTHING AND SHOES. INGESTION: DO NOT INDUCE
VOMITING. ALLOW VICTIM TO RINSE HIS MOUTH AND THEN TO DRINK 2-4
CUPFULS OF WATER, AND SEEK MEDICAL ADVICE. INHALATION: REMOVE FROM
EXPOSURE TO FRESH AIR IMMEDIATELY. NOTES TO MD: TREAT
SYMPTOMATICALLY AND SUPPORTIVELY.
===================== Fire Fighting Measures =====================
Flash Point:NOT AVAILABLE
Autoignition Temp:Autoignition Temp Text:N/AV
Lower Limits:NOT AVAIL
Upper Limits:NOT AVAIL
Extinguishing Media:IN CASE OF FIRE, USE WATER, DRY CHEMICAL, CHEMICAL
FOAM, OR ALCOHOL-RESISTANT FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:DURING A FIRE, IRRITATING AND HIGHLY
TOXIC GASES MAY BE GENERATED BY THERMAL DECOMPOSITION AND
COMBUSTION. NFPA RATING: NOT PUBLISHED.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTIVE EQUIPMENT AS
INDICATED IN EXPOSURE CONTROLS, PERSONAL PROTECTION SECTION. CLEAN
UP SPILLS IMMEDIATELY, OBSERVING PRECAUTIONS IN THE PROTECTIVE
EQUIPMENT SECTION. SWEEP U P, THEN PLACE INTO A SUITABLE CONTAINER
FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH EYES, SKIN AND
CLOTHING. AVOID INGESTION OR INHALATION. STORE IN A COOL, DRY
PLACE. KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:USE APPROPRIATE PROCEDURES TO PREVENT OPPORTUNITIES
FOR DIRECT CONTACT WITH SKIN OR EYES AND TO PREVENT INHALATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH OR EUROPEAN STANDARD EN 149 APPROVED
FULL-FACEPIECE AIRLINE RESPIRATOR IN THE POSITIVE PRESSURE MODE
WITH EMERGENCY ESCAPE PROVISIONS.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
AIRBORNE CONCENTRATIONS BELOW THE PERMISSIBLE EXPOSURE LIMITS. USE
PROCESS (SUPDAT)
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
WEAR APPROPRIATE PROTECTIVE CLOTHING TO MINIMIZE CONTACT WITH SKIN
AND TO PREVENT SKIN EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
Supplemental Safety and Health
PHYSICAL AND CHEMICAL PROPERTIES: MOLECULAR FORMULA: NOT AVAILABLE.
MOLECULAR WEIGHT: 134.13. -- VENT: ENCLOSURE, LOCAL EXHAUST
VENTILATION, OR OTHER ENGINEERING CONTROLS TO CONTROL AIRBORNE
LEVELS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NOT AVAILABLE
Melt/Freeze Pt:=91.C, 195.8F
Decomp Temp:Decomp Text:NOT AVAILABLE
Vapor Pres:NOT AVAILABLE
Spec Gravity:NOT AVAILABLE
pH:NOT AVAILABLE
Viscosity:NOT AVAILABLE
Solubility in Water:SOLUBLE
Appearance and Odor:WHITE POWDER - SLIGHTLY YELLOW; NO ODOR AVAILABLE.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:STABLE UNDER NORMAL TEMPERATURES AND
PRESSURES. AVOID INCOMPATIBLE MATERIALS.
Hazardous Decomposition Products:CARBON MONOXIDE, IRRITATING AND TOXIC
FUMES AND GASES, CARBON DIOXIDE.
Conditions to Avoid Polymerization:HAS NOT BEEN REPORTED.
=================== Toxicological Information===================
Toxicological Information:THE TOXICOLOGICAL PROPERTIES OF THIS MATERIAL
HAVE NOT BEEN INVESTIGATED. SEE ACTUAL ENTRY IN RTECS FOR COMPLETE
INFORMATION.
===================== Ecological Information =====================
Ecological:FOR FURTHER INFORMATION, CONTACT ACROS ORGANICS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE AND LOCAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:U.S. DOT: SHIPPING NAME: NO INFORMATION
AVAILABLE. HAZARD CLASS; UN NUMBER; PACKING GROUP: N/P. --
I.M.O./I.A.T.A./R.I.D./A.D.R.: SHIPPING NAME; HAZARD CLASS; UN
NUMBER; PACKING GROUP: N/P. -- CANADIA N T.D.G.: SHIPPING NAME: NO
INFORMATION AVAILABLE. HAZARD CLASS; UN NUMBER; PACKING GROUP: N/P.
===================== Regulatory Information =====================
Federal Regulatory Information:EUROPEAN/INTERNATIONAL REGULATIONS:
EUROPEAN LABELING I/A/W EC DIRECTIVES: HAZARD SYMBOLS: NOT
AVAILABLE. RISK PHRASES: N/P. SAFETY PHRASES: S 24/25 - AVOID
CONTACT WITH SKIN AND EYES. WGK (WATER DANG ER/PROTECTION): CAS
#533-67-5: 1. CANADA: CAS #533-67-5 IS LISTED ON CANADA'S DSL/NDSL
LIST; CAS #533-67-5 IS NOT LISTED ON CANADA'S INGREDIENT DISCLOSURE
LIST. EXPOSURE LIMITS: N/P. U.S. FEDERAL: TSC A: CAS #533-67-5 IS
LISTED ON THE TSCA INVENTORY.
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:DANISH OIL DARK WALNUT,V-265-E-1
CAGE:HO176
CAGE:8P443
CAGE:HO176
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA (PETROLEUM SPIRITS OR BENZIN)
CAS:8030-30-6
RTECS #:SE7555000
Fraction by Wt: 59%
OSHA PEL:100 PPM
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 1.0%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:DENATURED ALCOHOL
RTECS #:AZ0875400
Fraction by Wt: 0.5%
ACGIH TLV:1000 PPM (MFR)
Ingred Name:CYCLOHEXANOL
CAS:108-93-0
RTECS #:GV7875000
Fraction by Wt: 0.15%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 50 PPM; 9192
Ingred Name:AROMATIC HYDROCARBON FRACTION
Fraction by Wt: 1.0%
ACGIH TLV:200 PPM (MFR)
===================== Hazards Identification =====================
Effects of Overexposure:INHAL:RESULTS FROM DIZZY & HEADACHE TO
UNCONSCIOUSNESS.SKIN:PRLNG/RPTD CONTACT-DRY, (SEE SUPP DATA)
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/PLENTY OF H*20 FOR 15 MIN/UNTIL IRRIT
SUBSIDES;CALL DR.SKIN:WASH W/SOAP,H*2O.REMOVE CONTAM CLTHG,WASH
BEFORE REUSE.INGEST: DO NOT INDUCE VOMIT,CALL DR.INHAL:REMOVE FROM
EXP IMMED;CALL DR.I F IRREGULAR/STOPPED BRTHG,GIVE ARTF RESP,GIVE
O*2.
===================== Fire Fighting Measures =====================
Flash Point:OVER 100F (38C)
Lower Limits:0.7
Extinguishing Media:FOAM,DRY CHEMICAL,CO*2,H*20 SPRAY/FOG.
Fire Fighting Procedures:USE SCBA.KEEP CNTNRS COOL W/H*20;DONT SPREAD
BURN LIQ Q/H*2O
Unusual Fire/Explosion Hazard:DONT APPLY TO HOT SURF.KEEP AWAY FROM
IGNIT SOURCES.DONT STORE/MIX W/STRONG OXIDANT(SEE OTHR PRECAUT
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNIT SOURCES.KEEP PEOPLE
AWAY.RECOVER FREE LIQUID.ADD ABSORBENT TO SPILL AREA.AVOID
BREATHING VAPOR.VENT AREA.KEEP OUT OF SEWERS,WATERCOURSES BY
DIKING.TELL AUTHORITIES IF HAS ENTERED/MAYENTER
SEWERS,WATERCOURSES/EXTENSIVE LAND AREAS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNR CLSD.DONT HANDL/STORE NEAR
IGNIT SOURCES/STRG OXIDANTS.ADEQ VENT REQ.NO SMOKING/OPEN
LIGHTS.GROUND CNTNRS IF POUR,LIMIT FREE FALL.
Other Precautions:AVOID BRTHG VAP/SKIN CONT.EMPTY CNTNR POSS HAZ FROM
PROD RESIDUE. UNUSUAL FIRE & EXPLO HAZ:KEEP CNTNR CLSD TIGHT.CLSD
CNTNR MAY EXPLODE IF EXPOSED TO EXTREME HEAT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD ORGANIC VAP
CANISTER/SUPPLIED-AIR RESP PROTECTION
Ventilation:SUFF MECHAMICAL VENT W/EXPLO-PROOF EQUIP TO KEEP < TLV.
Other Protective Equipment:SLVT RESISTANT APRON/OTHR CLTHG TO AVOID
SKIN CONTACT.
Supplemental Safety and Health
OVEREXP EFTS:DEFAT LEADING TO IRRIT,DERMATITIS.EYE:SEVERE
IRRIT,RED,TEAR,BLURRED VISION.INGEST:GASTROINTESTINAL
IRRIT,NAUSEA,VOMIT,DIARRHEA. PRODUCT DISCONTINUED DEC,1984.DATE OF
PREP:6/13/84.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:165-405F
Vapor Density:> 1
Spec Gravity:0.8954
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:69
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
O*2,STRONG OXIDANTS.WILL DISSOLVE/SOFTEN SOME PLASTIC,RUBBER
Stability Condition to Avoid:HIGH TEMP/DIRECT HEATING.
Hazardous Decomposition Products:SMOKE,ACRID FUMES,CO*2,POSS
ACROLEIN.INCOMPLETE COMB-CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IAW FEDERAL,STATE & LOCAL REGULATIONS.
ASSURE CONFORMITY W/APPLICABLE DISPOSAL REGULATIONS FOR BOTH
SPILLED PRODUCT & ABSORBED MATERIAL.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:MT TONER II, EP4301
CAGE:GO339
CAGE:GO339
CAGE:23736
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE ACRYLATE COPOLYMER
Fraction by Wt: >80%
Ingred Name:COPPER OXIDE
CAS:1317-38-0
RTECS #:GL7900000
Fraction by Wt: 5-10%
OSHA PEL:0.1 MG/M3 FUME (CU)
ACGIH TLV:0.2 MG/M3 FUME (CU)
Ingred Name:ORGANIC PIGMENT
CAS:32517-36-5
Fraction by Wt: 1-5%
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 1-5%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:PROPENE POLYMERS (POLYPROPYLENE)
CAS:9003-07-4
RTECS #:UD1842000
Fraction by Wt: 1-3%
Ingred Name:TONER POWDER MIX. (AS TOTAL NUISANCE DUST). TONER, AS A
MIXTURE, IS CONSIDERED A NUISANCE DUST.
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL, RAT) >5 G/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MINIMAL RESP TRACT IRRIT MAY
OCCUR AS W/EXPOSURE TO LGE AMT OF ANY NONTOXIC DUST. MAY CAUSE
COUGH & RAISE PHLEGM. CHRONIC: NONE. TONER PRESENTS LOW HAZ FOR
USUAL OCCUP SETTINGS. BASED ON AVAIL DATA, HUMAN EXPOSURE TO TONER
HAS BEEN SHOWN TO CAUSE MINIMAL RESP TRACT IRRIT AS MAY OCCUR W/LGE
AMTS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: OF ANY NON-TOXIC DUSTS. RSLTS OF ONE
ANIMAL STUDY WHERE RATS INHALED TONER THAT WAS 10X MORE RESPIRABLE
THAN COMMERCIALLY AVAIL TONER WERE OBSERVED TO HAVE NO LUNG CHANGES
AT LOW EXPOS (THE MOST RELEVANT LEVEL TO POTNTL HUMAN EXPOS). AT
HIGHER LEVELS A SLIGHT DEGREE OF LUNG FIBROSIS WAS OBSERVED (SUPP
DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: WASH NOSTRILS, RINSE MOUTH. INGEST: DILUTE STOMACH
CONTENTS W/SEVERAL GLASSES OF WATER. EYES: FLUSH W/WATER FOR A
MINIMUM OF 15 MINUTES. SKIN: WASH W/SOAP & WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:TONER IS A COMBUSTIBLE POWDER. WHEN
DISPERSED IN AIR, IT FORMS EXPLOSIVE MIXTURES.
================== Accidental Release Measures ==================
Spill Release Procedures:IF SPILLED, SWEEP UP OR VACUUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN MINOLTA
EQUIPMENT.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE.
Supplemental Safety and Health
EFTS OF OVEREXP: DUE TO EXCESSIVE AMOUNTS OF DUST RETAINED IN THE LUNGS
FOR A PROLONGED INTERVAL.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.2
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER, FAINT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION ARE TOXIC.
AVOID BREATHING OF SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE. NO SPECIAL TECHNIQUES BEYOND
NORMAL PRACTICE. ENSURE CONFORMITY W/FEDERAL, STATE, AND LOCAL
REGULATIONS.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:INNERBOND 2010 FLUID 10 CST
CAGE:66172
CAGE:66172
============= Composition/Information on Ingredients =============
Ingred Name:HEXAMETHYLDISILOXANE
Other REC Limits:NONE SPECIFIED
Ingred Name:TETRADECAMETHYLHEXASILIXONE
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:DERMAL LD50 (RAT) IS 2000 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: DROWSINESS, DIZZINESS, AND
HEADACHES. EYES: TEARING, REDNESS, MILD BURNING SENSATION. SKIN:
MILD IRRITATION. INGESTION: MILD NAUSEA.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN CONDITIONS MAY BE
AGGRAVATED BY OVEREXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF SYMPTOMS PERSIST, SEE
DOCTOR. EYES: FLUSH WITH PLENTY OF WATER FOR 15 MINUTES. SEE
DOCTOR. SKIN: REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND
WATER FOR AT LEAST15 MINUTES. IF SYMPTOMS PERSIST, SEE DOCTOR.
INGESTION: INDUCE VOMITING. SEE DOCTOR IMMEDIATELY. IF ANY SYMPTOMS
LAST LONGER THAN 24 HOURS, SEE DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:55.4F,13.0C
Extinguishing Media:FOAM, CARBON DIOXIDE, OR DRY CHEMICAL.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:FLAMMABLE LIQUID. COOL CONTAINERS WITH
WATER FOG. MATERIAL MAY REIGNITE WHEN FLOATING ON TOP OF WATER.
================== Accidental Release Measures ==================
Spill Release Procedures:ISOLATE AREA. ELIMINATE ALL SOURCES OF
IGNITION. ABSORB WITH VERMICULITE AND SWEEP INTO STEEL DRUM FOR
LATER DISPOSAL. CONTACT LOCAL ENVIRONMENTAL MANAGER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL(<77F), DRY AREA. TAKE
PRECAUTIONS AGAINST STATIC ELECTRICITY.
Other Precautions:DO NOT EAT, DRINK, OR SMOKE IN THE WORK AREA. USE
PROPER BONDING AND GROUNDING PROCEDURES DURING TRANSFER OPERATIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC
VAPORS CARTRIDGE.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION. USE EXPLOSION PROOF
EQUIPMENT.
Other Protective Equipment:GREASE/OIL RESISTENCE CLOTHING.
Work Hygienic Practices:WASH HANDS AFTER HANDLING. LAUNDER CLOTHING
BEFORE REUSE.
Supplemental Safety and Health
AVOID INHALATION AND INGESTION.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:199F,93C
Vapor Pres:0.74 @104F
Spec Gravity:0.847 @ 77F
pH:UNKNON
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS, SLIGHT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG MINERAL ACIDS AND STRONG ALKALIS.
Stability Condition to Avoid:ALL SOURCES OF IGNITION, SUCH AS HEAT,
SPARKS, FLAME.
Hazardous Decomposition Products:SILICA AND OXIDES OF CARBON MAY BE
FORMED ON COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:BURY IN A SANITARY LANDFILL IN ACCORDANCE WITH
LOCAL, STATE AND FEDERAL REGULATIONS. CONTACT LOCAL ENVIRONMENTAL
MANAGER FOR PROPER PROCEDURES.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:8111 (MOULDABLE WOOD) LIQUID, 1407/0559
CAGE:67020
CAGE:0PX05
CAGE:67020
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE (SARA 313)
CAS:100-42-5
RTECS #:WL3675000
Fraction by Wt: 10-30%
OSHA PEL:100 PPM
ACGIH TLV:S, 50 PPM/100 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL,RAT) 5,000 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: SKIN, EYES AND RESPIRATORY
TRACT IRRITATION. VAPORS ARE CENTRAL NERVOUS SYSTEM (CNS)
DEPRESSANT, INHALATION OF VAPORS ALSO CAUSES NAUSEA, VOMITING,
DIZZINESS, DISORIENTATION AND UNCONSCIOUSNESS MAY OCCUR AT HIGH
CONCENTRATIONS. CHRONIC: IRRITATION, DERMATITIS.
Explanation of Carcinogenicity:STYRENE: MONOGRAPHS, SUPPLEMENT, VOL 60,
PG 223, 1994: GROUP 2B.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:SKIN, EYE, RESPIRATORY TRACT AND
CNS CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE SOURCE OF CONTAM &/OR MOVE VICTIM TO FRESH AIR.
IF RECOVERY IS DELAYED/THERE ARE SIGNS OF DISTRESS OBTAIN MED ATTN
IMMED. EYE CONT: FLUSH W/WATER FOR AT LST 15 MINS. SEEK MED ADVICE
IF A NY IRRIT PERSISTS. SKIN CONT: IMMED REMOVE EXCESS W/CLEAN
CLOTH & WASH SKIN THORO W/SOAP & WATER. IF IRRIT/INFLAMM PERSISTS,
SEEK MED ADVICE. INGEST: DO NOT INDUCE VOMIT. RINSE MOUTH W/WATER
(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:93.2F,34.0C
Lower Limits:1.1%
Upper Limits:6.1%
Extinguishing Media:WATER SPRAY, FOG OR MIST, FOAM, CARBON DIOXIDE, DRY
CHEMICALS, SAND ETC.
Fire Fighting Procedures:NIOSH APPRVD SCBA & FULL PROT EQUIP . USE SAND
TO CNTN BURNING MATL. COOL CNTNRS EXPOSED TO FLAMES W/WATER. KEEP
RUN-OFF WATER OUT OF SEWERS OR (SUPDAT)
Unusual Fire/Explosion Hazard:VAPORS CAN FORM EXPLOSIVE MIST W/AIR &
VAPORS MAY TRAVEL CONSIDERABLE DISTANCE TO ANY SOURCES OF IGNIT &
FLASH BACK. DECOMPOSITION & COMBUST MAY BE HAZARDOUS.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH AN INERT MATERIAL (E.G. EARTH OR
SAND). SWEEP UP, PLACE INTO SUITABLE LABELLED CONTAINERS, SEAL AND
DISPOSE OF PROPERLY. FLUSH AREA WITH DETERGENT AND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:OVERHEATING MAY CAUSE CONTAINERS TO
RUPTURE. CONTAINERS SHOULD BE STORED UNDER COOL, DRY CONDITIONS.
Other Precautions:EMPTY CONTAINERS WILL RETAIN RESIDUE AND MAY BE
DANGEROUS. CHECK ALL CONTAINERS FOR LEAKS AT REGULAR INTERVALS &
BEFORE USE. AVOID CONTACT WITH SKIN AND EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT APPLICABLE UNDER NORMAL CONDITIONS OF USE.
NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:WHERE ADEQUATE NATURAL VENTILATION IS NOT AVAILABLE PROVIDE
SUITABLE LOCAL EXHAUST VENTILATION.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
SUITABLE PROTECTIVE CLOTHING.
Work Hygienic Practices:WASH HANDS W/SOAP & WATER & USE HAND CREAM.
REMOVE CONTAMD CLTHG & WASH BEFORE REUSE.
Supplemental Safety and Health
SOL IN H*2O: NEGLIGIBLE (0.03G/100G H*2O @ 20C). FIRE FIGHT PROC: WATER
SOURCES. IF WATER POLLUTION OCCURS, NOTIFY APPROP AUTH IMMED. FIRST
AID PROC: & DRINK PLENTY OF WATER. CALL TAMPA BAY REGIONAL P OIS
NITRILE OR PVC.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:293F,145C
Vapor Pres:4.5 @ 20C
Vapor Density:3.6
Spec Gravity:1.14
Evaporation Rate & Reference:0.4 (BUAC =1)
Solubility in Water:SUPP DATA
Appearance and Odor:CLEAR BROWN LIQUID WITH STYRENE ODOR.
Percent Volatiles by Volume:10-30
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS AND ACIDS.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:GASEOUS COMBINATIONS OF CARBON,
HYDROGEN AND OXYGEN MAY OCCUR AT ELEVATED TEMPERATURES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:1109 ULTRA SPRAY ENAMEL
CAGE:EO706
CAGE:EO706
CAGE:07708
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 33-42%
OSHA PEL:2400 MG/CUM
ACGIH TLV:750 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL ACETATE
CAS:141-78-6
RTECS #:AH5425000
Fraction by Wt: 0-5%
Other REC Limits:400 PPM
OSHA PEL:1400 MG/CUM
ACGIH TLV:1400 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHANOL (ETHYL ALCOHOL), TECSOL, ALCOHOL, SYNASOL
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 5-10%
Other REC Limits:1900 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ingred Name:ETHYL 3-ETHOXYPROPIONATE, PROPANOIC ACID, 3-ETHOXY-, ETHYL
ESTER *96-1*
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: 5-10%
Ingred Name:2-BUTANONE (METHYL ETHYL KETONE) (MEK)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 0-5%
Other REC Limits:590 MG/CUM
OSHA PEL:200 PPM
ACGIH TLV:590 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *96-1*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 5-10%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HYDROCARBON PROPELLANT, PETROLEUM GASES LIQUIFIED
SWEETENED, C3-7 *96-1*
CAS:68476-86-8
Fraction by Wt: 23%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: EXCESSIVE VAPORS CAN CAUSE
NASAL & RESPIRATORY IRRITATION & EVEN ASPHYXIATION. EYES: SEVERE
IRRITATION. INGESTION: GI IRRITATION. SKIN: CAN CAUSE IRRITATION
FOR SOME PERSONS. REPEATED/PROL ONGED OVEREXPOSURE TO SOLVENTS MAY
CAUSE PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE. (SEE SUPP)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DIZZINESS, WEAKNESS, FATIGUE,
NAUSEA, HEADACHE, UNCONSCIOUSNESS, REDNESS, TEARING, BLURRED
VISION, VOMITING, DIARRHEA.
Medical Cond Aggravated by Exposure:BY EXPOSURE-CAN CAUSE RESPIRATORY
&/SKIN REACTION.S
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED.
EYES: FLUSH W/WATER FOR 15 MINS. INGESTION: DON'T INDUCE VOMITING.
ASPIRATION OF MATERIAL INTO LUNGS CAN CAUSE PNEUMONIC, WHICH CAN BE
FATAL . KEEP WARM & QUIET. SKIN: WASH W/SOAP & WATER/VARIOUS HAND
CLEANERS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:0F
Lower Limits:1
Extinguishing Media:ALCOHOL FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. USE WATER TO
COOL CLOSED CONTAINERS. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE. (SEE SUPP)
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE &/IGNITE
WHEN EXPOSED TO EXTREME HEAT. (SEE SUPP)
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. VENTILATE AREA.
ABSORB LIQUID ON PAPER, VERMICULITE, FLOOR ABSORBENT/OTHER
ABSORBENT MATERIAL & TRANSFER TO A CLOSED CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T PUNCTURE/INCINERATE. DON'T STORE
IN AREAS >120F/DIRECT SUNLIGHT/NEAR HEAT/OPEN FLAMES.
Other Precautions:STORE LARGE QUANTITIES IN BUILDING PROTECTED FOR
STORAGE OF FLAMMABLE LIQUIDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR CASUAL/OCCASIONAL USE-WEAR RESPIRATORY
PROTECTION/LEAVE THE AREA.
Ventilation:FOR REGULAR/CONTINUOUS USE-PROVIDE SUFFICIENT MECHANICAL
(GENERAL) &/LOCAL EXHAUST TO KEEP EXPOSURE BELOW TLVS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:133-331F
Melt/Freeze Pt:M.P/F.P Text:1500F
Vapor Density:>1
Spec Gravity:<1
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT TO MODERATE
Appearance and Odor:TYPICAL SOLVENT PAINT
Percent Volatiles by Volume:80-90
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME & OTHER IGNITION
SOURCES.
Hazardous Decomposition Products:WHEN BURNED: CO2, CO, VARIOUS
HYDROCARBONS, NITROGEN COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:COLLECT ON ABSORBENT MATERIAL, MAY BE DEPOSITED
IN A POSTED TOXIC SUBSTANCE LANDFILL IAW/FEDERAL, STATE & LOCAL
REGULATIONS. UN1950.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:FP-902 FLUORESCENT PENETRANT
CAGE:98733
CAGE:98733
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM HYDROCARBON (HYDROTREATED MIDDLE PETROLEUM
DISTILLATE)
CAS:64742-46-7
RTECS #:JN9379645
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Effects of Overexposure:EYES: LIQUID CONTACT MAY CAUSE IRRITATION.
SKIN: CAUSES SLIGHT IRRITATION. INHALATION: VAPOR OR OIL MIST MAY
CAUSE MILD IRRITATION OF UPPER RESPIRATORY TRACT. INGESTION: MAY
RESULT IN VOMITING. ASPIRA TION MUST BE AVOIDED.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN AND RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH RUNNING WATER FOR AT LEAST 15 MINUTES. GET
MEDICAL HELP IF IRRITATION PERSISTS. SKIN:FLUSH WITH WATER. WASH
WITH SOAP AND WATER. INHALATION:REMOVE TO FRESH AIR, PROVIDE OXYGEN
IF BREAT HING IS DIFFICULT. INGESTION:DO NOT INDUCE VOMITING. GET
MEDICAL ASSISTANCE FOR ANY OF HEALTH PROBLEMS.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:210F,99C
Extinguishing Media:WATER FOG,DRY CHEMICAL,CARBON DIOXIDE OR FOAM; DO
NOT USE DIRECT STREAM OF WATER ON THE FIRE.
Fire Fighting Procedures:IN CONFINED AREA,DO NOT ENTER WITHOUT A FULL
BUNKER GEAR INCLUDING A POSITIVE PRESSURE NIOSH APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CONTAINERS MAY BURST AND/OR RUPTURE IN
INTENSE HEAT OF FIRE. PER MANUFACTURER,PRODUCT MAY IGNITE IN AIR
WHEN EXPOSED TO FLAME OR PREHEATED.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES.WEAR APPROPRIATE
PROTECTIVE CLOTHING AND RESPIRATORS.SOAK UP WITH ABSORBENT.PLACE
WASTE IN SEALED CONTAINERS.FLUSH WITH WATER.LARGE SPILL:DIKE LIQUID
& PUMP INTO SALVAGE TAN K.ABSORB RESIDUE WITH COMM ABSORBENT & PUT
IN DRUM
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM SOURCES OF
HEAT/IGNITION.STORE IN COOL,DRY & VENTILATED AREA.DO NOT STORE NEAR
OXIDIZING MATERIAL;AVOID PHYSICAL DAMAGE TO CONTAINERS.
Other Precautions:MINIMIZE SKIN CONTACT.AVOID BREATHING VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NEEDED IN NORMAL CONDITIONS OR WHEN
VAPORS/MIST CONCENTRATIONS ARE BELOW TLV/PEL LIMITS. WEAR NIOSH
APPROVED ORGANIC TYPE RESPIRATOR IN ABSENCE OF PROPER ENVIRONMENTAL
CONTROL.
Ventilation:LOCAL EXHAUST OR MECHANICAL(GENERAL) TO MAINTAIN TLV OR
BELOW TLV LIMITS.
Other Protective Equipment:CHEMICAL RESISTANT APRON TO PREVENT
CLOTHING/SKIN CONTACT.
Work Hygienic Practices:WASH HANDS WITH SOAP & WATER BEFORE EATING,
SMOKING OR USING TOILET FACILITIES;DO NOT EAT/DRINK IN VAPOR
CONTMNTD AREA.
Supplemental Safety and Health
NSN FOR TYPE I,METHOD A,LEVEL 2 OF MIL-I-25135,REV E; PER QPL-25135-15
FP-902 IS A QUALIFIED PRODUCT FOR THIS NSN.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>400F,>204C
Spec Gravity:ABOUT 0.86
Solubility in Water:NEGLIGIBLE
Appearance and Odor:YELLOW-GREEN LIQUID, SLIGHT HYDROCARBON ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL
Stability Condition to Avoid:SOURCE OF HEAT/IGNITION. AVOID EXPOSURE TO
OXIDANTS.
Hazardous Decomposition Products:COMBUSTION CAN PRODUCE OXIDES OF
CARBON AND UNIDENTIFIED ORGANIC COMPOUNDS.
Conditions to Avoid Polymerization:HEAT, OPEN FLAMES AND OXIDIZING
MATERIALS.
==================== Disposal Considerations ====================
Waste Disposal Methods:PER MANUFACTURER, PLACE IN APPROPRIATE DISPOSAL
FACILITY IN FULL COMPLIANCE WITH ALL FEDERAL STATE & LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: CF 124 FILLER FOAM
Cage: 11239
=======================================================
Contractor Summary
=======================================================
Cage: 11239
Box: 21148
=======================================================
Ingredients
=======================================================
Cas: 75-68-3
RTECS #: KH7650000
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
Ozone Depleting Chemical: 2
------------------------------
Cas: 9016-87-9
RTECS #: TR0350000
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Cas: 74-98-6
RTECS #: TX2275000
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 1000 PPM
ACGIH TLV: ASPHYXIANT; 9394
------------------------------
Cas: 106-97-8
RTECS #: EJ4200000
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 800 PPM
ACGIH TLV: 800 PPM; 9394
------------------------------
Cas: 68037-64-9
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Cas: 6425-39-4
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 74-98-6
RTECS #: TX2275000
OSHA PEL: 1000 PPM
ACGIH TLV: ASPHYXIANT
------------------------------
Cas: 106-97-8
RTECS #: EJ4200000
OSHA PEL: 800 PPM
ACGIH TLV: 800 PPM
------------------------------
RTECS #: 9999999VO
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
PERSON. OTHER:REFERRAL TO PHYS IS REC
-----------------------------
-----------------------------
FROM FREEZING.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NOT GIVEN FOR PRODUCT AS A WHOLE
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: MAY CAUSE EYE, SKIN AND RESPIRATORY IRRITATION.
SENSITIZER.
Explanation Of Carcinogenicity: THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Signs And Symptions Of Overexposure: EYE IRRITATION, SKIN IRRITATION,
RESPIRATORY TRACT IRRITATION.
Medical Cond Aggravated By Exposure: PRE-EXISTING EYE, SKIN AND/OR RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
First Aid: EYES: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS OPEN.
GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND
WATER. IF IRRITATION PERSISTS, GET MEDICAL ATTENTION. IN HALATION: REMOVE TO
FRESH AIR. RESTORE BREATHING. GET MEDICAL ATTENTION. INGESTION: DO NOT INDUCE
VOMITING. GET MEDICAL ATTENTION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: CF124 FILLER FOAM WILL POLYMERIZE (CURE) UPON CONTACT
WITH AIR/MOISTURE. ALLOW PRODUCT TO CURE, THEN REMOVE FOR DISPOSAL.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR LINER IN
ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
Handling And Storage Precautions: EXTREMELY FLAMMABLE. CONTENTS UNDER PRESSURE.
DO NOT STORE ABOVE 100F. STORE IN A COOL, DRY PLACE. KEEP AWAY FROM IGNITION
SOURCES SUCH AS HEAT, SPARK
Other Precautions: DO NOT SOTRE IN DIRECT SUNLIGHT. KEEP FROM FREEZING. AVOID
CONTACT WITH EYES AND SKIN. KEEP AWAY FROM CHILDREN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: <0F(PROPELLANTS)
Lower Limits: 4 %
Upper Limits: 18 %
Extinguishing Media: FOAM, DRY CHEMICAL, CARBON DIOXIDE
Fire Fighting Procedures: FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER SPRAY TO
COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard: OVERHEATED CANS CAN RUPTURE FROM PRESSURE
BUILD-UP AND BE PROPELLED THROUGH THE AIR.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT NORMALLY REQUIRED. A NIOSH-APPROVED POSITIVE
PRESSURE AIRLINE RESPIRATOR IS REQUIRED WHEN WORKING IN CONFINED SPACES.
Ventilation: GENERAL (I.E., NATURAL OR MECHANICALLY INDUCED FRESH AIR MOVEMENTS
THAT MAINTAIN VAPOR CONCENTRATION BELOW TLV'S.
Other Protective Equipment: PROTECTIVE CLOTHING AS REQUIRED TO AVOID SKIN
CONTACT. AN EMERGENCY EYE WASH STATION AND SHOWER SHOULD BE AVAILABLE.
Work Hygienic Practices: WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT AND
BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health: LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
B.P. Text: NOT GIVEN
M.P/F.P Text: NOT GIVEN
Decomp Text: UNKNOWN
Vapor Pres: 44 PSI
Vapor Density: > 1 (POLY)
Spec Gravity: 1.15
Solubility in Water: NOT SOLUBLE
Appearance and Odor: BROWN LIQUID EXPANDING TO FOAM ON CONTACT WITH AIR. SWEET
ETHEREAL ODOR
Corrosion Rate: UNKNOWN
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: EXCESS HEAT. CONTACT WITH AIR OR MOISTURE WILL
CAUSE FOAM TO POLYMERIZE.
Materials To Avoid: ALCOHOLS, STRONG BASES, ALKALI METAL COMPOUNDS. REACTS
NONVIOLENTLY WITH WATER.
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE, CYANIDE,
ISOCYANATES, OXIDES OF NITROGEN, CHLORINE, POX.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NONE. WILL NOT OCCUR.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 38596
Product ID: CF 124 FILLER FOAM
Review Date: 08/03/1994
Tech Entry NOS Shipping Nm: CONTAINS PROPANE, BUTANE
Multiple KIT Number: 0
Review IND: Y
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: AGC
DOT Proper Shipping Name: AEROSOLS, FLAMMABLE,
DOT PSN Modifier: (EACH NOT EXCEEDING 1 L CAPACITY)
Hazard Class: 2.1
UN ID Num: UN1950
Label: FLAMMABLE GAS
Special Provision: N82
Non Bulk Pack: NONE
Bulk Pack: NONE
Max Qty Pass: 75 KG
Max Qty Cargo: 150 KG
Vessel Stow Req: A
Water/Ship/Other Req: 40,48,85
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: AKD
IMO Proper Shipping Name: AEROSOLS o
IMDG Page Number: 2102
UN Number: 1950
UN Hazard Class: 2(T)
IMO Packaging Group: -
Subsidiary Risk Label: T
EMS Number: 2-13
MED First Aid Guide NUM: 620
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ALS
IATA UN ID Num: 1950
IATA Proper Shipping Name: AEROSOLS, FLAMMABLE
IATA PSN Modifier: (EACH NOT EXCEEDING 1 L CAPACITY)
IATA UN Class: 2.1
IATA Label: FLAMMABLE GAS
Packing Note Passenger: 203
Max Quant Pass: 75KG
Max Quant Cargo: 150KG
Packaging Note Cargo: 203
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ALR
AFI Symbols: *
AFI Proper Shipping Name: AEROSOLS, FLAMMABLE, N.O.S.
AFI PSN Modifier: (EACH NOT EXCEEDING 1L CAPACITY)
AFI Hazard Class: 2.1
AFI UN ID NUM: UN1950
Special Provisions: P4
Back Pack Reference: A6.3
=======================================================
HAZCOM Label
=======================================================
Product ID: CF 124 FILLER FOAM
Cage: 11239
Company Name: HILTI INC
Street: 5400 S 122ND E AVE
PO Box: 21148
Zipcode: 74121
Label Required IND: Y
Date Of Label Review: 08/03/1994
Status Code: C
MFG Label NO: NONE
Label Date: 08/03/1994
Origination Code: F
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Severe
Reactivity Hazard: Moderate
Hazard And Precautions: MAY CAUSE EYE, SKIN AND RESPIRATORY IRRITATION.
SENSITIZER. EXTREMELY FLAMMABLE. CONTENTS UNDER PRESSURE. DO NOT STORE ABOVE
100F. STORE IN A COOL, DRY PLACE. KEEP AWAY FROM IGNITION SOURCES SUCH AS H
EAT, SPARK FIRST AID: EYES: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING
EYELIDS OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. WASH
WITH SOAP AND WATER. IF IRRITATION PERSISTS, GET MEDICAL ATTENTION.
INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. GET MEDICAL ATTENTION.
INGESTION: DO NOT INDUCE VOMITING. GET MEDICAL ATTENTION.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:20804-1263 SMDC SHIELDED MILD DETONATING CORD
Preparer's Name:S SCHOOLFIELD/J KOHRING
CAGE:17610
CAGE:17610
============= Composition/Information on Ingredients =============
Ingred Name:X-CHORD, 2.5 GRAINS/FT, SILVER SHEATH
ACGIH TLV:0.1 MG/CUM
Ingred Name:HEXANITROSTILBENE I
ACGIH TLV:10.0 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION TO THE NOSE,
THROAT & MUCOUS MEMBRANE, ALLERGIC REACTIONS. SKIN: IRRITATION &
ABSORPTION, ALLERGIC REACTIONS. EYES: IRRITATION. INGESTION: TOXIC,
MAY CAUSE DEATH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, NAUSEA, REDNESS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER.
INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:DON'T ATTEMPT TO EXTINGUISH. EVACUATE AREA.
USE SCBA TO CONTAIN RESULTING FIRE.
Unusual Fire/Explosion Hazard:IF EXPOSED TO FIRE, THE UNIT MAY
ACTUATE/EXPLODE.
================== Accidental Release Measures ==================
Spill Release Procedures:CALL LOCAL HAZARDOUS MATERIALS TEAM. REMOVE
IGNITION SOURCES. COVER ANY EXPOSED MATERIAL W/VEGETABLE OIL &
REMOVE FOR APPROVED DISPOSAL. USE FLAME RETARDANT CLOTHING, SAFETY
GLASSES & NON-SPARKING TOO LS.
======================Handling and Storage ======================
Handling and Storage Precautions:ANTI-STATIC ARE TO BE USED FOR STORAGE
& SHIPPING.
Other Precautions:THIS MSDS ISN'T INTENDED TO BE AN ORDNANCE HANDLING
DOCUMENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH APPROVED HEPA RESPIRATOR IF PEL/TLV
IS EXCEEDED.
Ventilation:LOCAL EXHAUST: REQUIRED FOR TEST FIRING.
Other Protective Equipment:FLAME RETARDANT COAT & GROUNDING STRAPS TO
PREVENT ELECTROSTATIC DISCHARGE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:INSOLUBLE
Appearance and Odor:SMDC: SILVER; ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALIS, ACIDS, BRONZE, CORROSIVES & OXIDIZERS.
Stability Condition to Avoid:MECHANICAL SHOCK, STATIC ELECTRICITY,
HEAT, FLAME/SPARKS.
Hazardous Decomposition Products:CO, NITROGEN, NITROUS OXIDES,
HYDROGEN, CARBON, CO2 & WATER.
==================== Disposal Considerations ====================
Waste Disposal Methods:UNFIRED UNITS/WASTE SHOULD BE DISPOSED AS
REACTIVE (D003) & TOXIC (D011) HAZARDOUS WASTE, IAW/FEDERAL, STATE
& LOCAL REGULATIONS. UN-0367.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:TT-E-2784 GREEN #34127
Preparer's Name:ONEY FLEMING
CAGE:JO954
CAGE:JO954
CAGE:39934
============= Composition/Information on Ingredients =============
Ingred Name:PROPYLENE GLYCOL
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: 6.25%
Other REC Limits:NONE RECOMMENDED
Ingred Name:2,2,4-TRIMETHYL-1-3,3,-PENTANEDIOL MONOISOBUTYRATE
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: 4.86%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIMETHYLAMINOETHANOL
CAS:108-01-0
RTECS #:KK6125000
Fraction by Wt: 0.38%
Other REC Limits:NONE RECOMMENDED
Ingred Name:2-N-OCTYL-4-ISOTHIAZOLIN-3-ONE
CAS:26530-20-1
Fraction by Wt: 0.18%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: 88.33%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
Ingred Name:VOC = 1.6 LBS/GL
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: HEADACHE, NAUSEA, IRRITATION.
EYE: IRRITATION. SKIN: IRRITATION.
Medical Cond Aggravated by Exposure:LUNG DISEASE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LARGE AMOUNTS OF WATER FOR 15 MINUTES, CALL DR.
SKIN: WASH THOROUGHLY W/SOAP & WATER. INGEST: GIVE 2 GLASSES OF
WATER TO DRINK. CALL DR.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>212F,>100C
Autoignition Temp:Autoignition Temp Text:216F
Lower Limits:NONE
Upper Limits:NA
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL & WATER FOG.
Fire Fighting Procedures:WEAR SCBA & FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:MATERIAL MAY SPLATTER ABOVE 212F. POLYMER
FILM MAY BURN.
================== Accidental Release Measures ==================
Spill Release Procedures:EVAC AREA. FLOOR MAY BE SLIPPERY. CONTAIN
SPILL W/INERT MATERIAL. TRANSFER LIQUID/ABSORBENT TO SEPARATE
SUITABLE CONTAINER FOR RECOVERY/DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING.
Other Precautions:KEEP AWAY FROM CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MECHANICAL FILTER RESPIRATOR.
Ventilation:NORMAL (FAN).
Other Protective Equipment:EYEWASH STATION.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212 TO 644F
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Decomp Temp:Decomp Text:350F,177C
Vapor Pres:NONE
Vapor Density:>AIR
Spec Gravity:1.14
pH:<9.0
Viscosity:77-95 KU
Evaporation Rate & Reference:<ETHER
Solubility in Water:SLIGHT.
Appearance and Odor:LIQUID, W/SLIGHT ODOR.
Percent Volatiles by Volume:60.6
Corrosion Rate:NA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NK
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:ACRYLIC MONOMERS.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP OUT OF SEWERS/OPEN BODIES OF WATER. CONSULT
FEDERAL, STATE & LOCAL AUTHORITIES FOR PROPER DISPOSAL PROCEDURES.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: MAGENTA TONER CARTRIDGE, 12A1451
Cage: 05487
=======================================================
Contractor Summary
=======================================================
Cage: 05487
=======================================================
Ingredients
=======================================================
80100252-5001P)
% low Wt: 75.
% high Wt: 85.
OSHA PEL: NOT ESTABLISHED.
ACGIH TLV: NOT ESTABLISHED.
-----------------------------
% low Wt: 5.
% high Wt: 10.
OSHA PEL: NOT ESTABLISHED.
ACGIH TLV: NOT ESTABLISHED.
-----------------------------
Cas: 114803-11-1
% low Wt: .5
% high Wt: 1.5
OSHA PEL: NOT ESTABLISHED.
ACGIH TLV: NOT ESTABLISHED.
-----------------------------
Cas: 5281-04-9
% low Wt: 3.
% high Wt: 4.
OSHA PEL: NOT ESTABLISHED.
ACGIH TLV: NOT ESTABLISHED.
------------------------------
Cas: 9010-79-1
% low Wt: 2.
% high Wt: 3.
OSHA PEL: NOT ESTABLISHED.
ACGIH TLV: NOT ESTABLISHED.
------------------------------
Cas: 7631-86-9
% low Wt: 1.
% high Wt: 1.5
Other REC Limits: ACGIH 3 MG/M3 RESP
OSHA PEL: 80 MG/M3/%SI*O2 CALC
ACGIH TLV: 10 MG/M3 (INHALABLE
------------------------------
Cas: 68909-20-6
% low Wt: .2
% high Wt: .4
OSHA PEL: NOT ESTABLISHED.
ACGIH TLV: NOT ESTABLISHED.
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: POTENTIAL HEALTH EFFECTS: INHALATION - SHORT TERM
EXPOSURE: TESTING AND/OR INFORMATION ON THIS OR SIMILAR TONERS, OR ON THE
CONSTITUENTS OF THIS TONER INDICATE LOW INHALATION TOXICITY. AS WITH EXPOSUR
E TO HIGH CONCENTRATIONS OF ANY DUST, MINIMAL RESPIRATORY TRACT IRRITATION
MAY OCCUR IF EXCESSIVE AMOUNTS OF TONER DUSTS ARE INHALED. LONG TERM
EXPOSURE: NO ADVERSE CHRONIC EFFECTS KNOWN AT INTENDED L EVEL OF USE.
EXPOSURE NOT PROBABLE WITH INTENDED USE. SKIN CONTACT - SHORT TERM EXPOSURE:
TESTING AND/OR INFORMATION ON THIS OR SIMILAR TONERS, OR THE CONSTITUENTS OF
THIS TONER INDICATE THIS TONER I S (SIGNS AND SYMPTOMS OF OVEREXPOSURE)
Signs And Symptions Of Overexposure: HEALTH HAZARDS ACUTE AND CHRONIC (CONT):
NOT A SKIN IRRITANT AND IS OF LOW DERMAL TOXICITY. LONG TERM EXPOSURE: RARE
INDIVIDUALS MAY NOTE SKIN RASH WITH REPEATED CONTACT. EXPOSURE NOT PROBABLE
WITHINTENDED USE. EYE CONTACT - SHORT TERM EXPOSURE: TONER MAY ACT AS A
MECHANICAL IRRITANT. LONG TERM EXPOSURE: NO ADVERSE CHRONIC EFFECTS KNOWN.
EXPOSURE NOT PROBABLE WITH INTENDED USE. INGESTION - SH ORT TERM EXPOSURE:
TESTING AND/OR INFORMATION ON THIS OR SIMILAR TONERS, OR ON THE CONSTITUENTS
OF THIS TONER INDICATE LOW ORAL TOXICITY. EXPOSURE NOT PROBABLE WITH INTENDED
USE. LONG TERM EXPOSURE: N O (SUPPLEMENTAL SAFETY AND HEALTH)
Medical Cond Aggravated By Exposure: NONE KNOWN AT INTENDED LEVELS OF USE.
EXPOSURE TO HIGH AIRBORNE DUST CONCENTRATIONS, INCLUDING TONER, MAY AGGRAVATE
EXISTING RESPIRATORY CONDITIONS.
First Aid: INHALATION: IF SYMPTOMS, SUCH AS SHORTNESS OF BREATH OR PERSISTENT
COUGHING ARE EXPERIENCED, REMOVE SOURCE OF CONTAMINATION AND MOVE INDIVIDUAL
TO FRESH AIR. IF SYMPTOMS PERSIST, SEEK MEDICAL ATTENTIO N. SKIN CONTACT:
WASH AFFECTED AREA WITH SOAP AND WATER. SHOULD IRRITATION OCCUR, SEEK MEDICAL
ATTENTION. EYE CONTACT: DO NOT RUB EYES. FLUSH IMMEDIATELY WITH PLENTY OF
WATER. REMOVE CONTACT LENSESAND CONTINUE FLUSHING FOR AT LEAST 15 MINUTES.
SEEK MEDICAL ATTENTION IF IRRITATION DEVELOPS AND PERSISTS. INGESTION: IF
CONSCIOUS, IMMEDIATELY WASH MOUTH OUT WITH PLENTY OF WATER. SEEK MEDICAL
ATTEN TION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: OCCUPATIONAL SPILL: IF A DUST CLOUD IS POSSIBLE DUE
TO A SPILL, REMOVE ALL SOURCES OF IGNITION SUCH AS OPEN SPARKS, FLAMES OR
STATIC DISCHARGE TO PREVENT IGNITION OF THE DUST. MINIMIZE DUST GENERATION
DURING CLEAN UP. SWEEP UP SPILL WITH NON-METALLIC BROOM AND DUST PAN. TO
AVOID POSSIBLE DUST EXPLOSION, DO NOT USE VACUUM CLEANERS TO CLEAN UP SPILLS.
CONTAIN FOR DISPOSAL. OIL (OTHER INFORMATION)
Waste Disposal Methods: THIS PRODUCT IS NOT A LISTED OR HAZARDOUS WASTE IN
ACCORDANCE WITH FEDERAL REGULATION 40 CFR PART 261 OR CODE OF CALIFORNIA
REGULATIONS TITLE 22. IF DISCARDED IN ITS PURCHASED FORM, THIS PRODUCT WOULD
NOT BE A HAZARDOUS WASTE BY EITHER LISTING OR BY CHARACTERISTIC. HOWEVER,
UNDER RCRA, IT IS THE RES PONSIBILITY OF PRODUCT USER TO (TRANSPORT INFO)
Handling And Storage Precautions: STORE IN A COOL DRY PLACE. STORE AWAY FROM
OXIDIZING MATERIALS.WHEN HANDLING, MINIMIZE GENERATION OF DUST. SUPPLY
ADEQUATE VENTILATION.
Other Precautions: PHYSICAL HAZARDS: AS WITH MOST FINELY DIVIDED DUSTS,
EXPLOSION IS POSSIBLE WHEN EXTREMELY HIGH CONCENTRATIONS OF DUST AND AN
IGNITION SOURCE ARE PRESENT. NOT A HAZARD UNDER NORMAL CONDITIONS OF USE.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Autoignition Temp Text: N/AV.
Extinguishing Media: CO2, WATER SPRAY OR FOG, DRY CHEMICAL, OR FOAM.
Fire Fighting Procedures: NIOSH APPROVED SELF CONTAINED BREATHING APPARATUS MAY
BE REQUIRED IF A LARGE NUMBER OF CARTRIDGES IS INVOLVED.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE REQUIRED FOR INTENDED USE IN PRINTER. IF
REQUIRED, USE A NIOSH APPROVED RESPIRATOR APPROPRIATE FOR THE EXPOSURE OF
CONCERN (FP N).
Ventilation: MECHANICAL ROOM VENTILATION.
GLASSES (FP N).
Other Protective Equipment: EYEWASH MEETING ANSI DESIGN CRITERIA (FP N).
PROTECTIVE CLOTHING: NONE REQUIRED FOR INTENDED USE IN PRINTER.
Supplemental Safety and Health: SIGNS AND SYMPTOMS OF OVEREXPOSURE (CONT):
ADVERSE CHRONIC EFFECTS KNOWN. EXPOSURE NOT PROBABLE WITH INTENDED USE.
SIGNS AND SYMPTOMS OF EXPOSURE: TONER ON SKIN OR MUCOUS MEMBRANES (MOUTH,
NOSE).
=======================================================
Physical/Chemical Properties
=======================================================
Vapor Pres: NOT AVAILABLE.
Spec Gravity: 1.16 @ 20C.
Solubility in Water: NEGLIGIBLE.
Appearance and Odor: MAGENTA ODORLESS POWDER
Percent Volatiles by Volume: NOT AVAIL.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: COMBUSTIBLE ATMOSPHERES OF TONER DUST. IGNITION
SOURCES, EXCESSIVE HEAT, SPARKS AND OPEN FLAME.
Materials To Avoid: STRONG OXIDIZERS.
Hazardous Decomposition Products: CARBON DIOXIDE, CARBON MONOXIDE, AND PHENOL
DERIVATIVES AT TEMPERATURES >300C.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: THIS PRODUCT WILL NOT POLYMERIZE.
=======================================================
Toxicological Information
=======================================================
Toxicological Information: ACUTE TOXICITY: NOT EXPECTED TO BE ACUTELY TOXIC.
CHRONIC TOXICITY: NOT EXPECTED TO BE TOXIC. EXPOSURE LIMITS:
OSHA: 15 MG/M3 (TOTAL DUST, PARTICULATES NOT OTHERWISE REGULATED-PNOR), 5 MG/M3
(RE SPIRABLE DUST, PARTICULATES NOT OTHERWISE REGULATED-PNOR), 80
MG/M3/%SI*O2 (TOTAL DUST, MEASURED AS AMORPHOUS SILICA). ACGIH: 10 MG/M3
(TOTAL DUST, PARTICULATES NOT OTHERWISE CLASSIFIED-PNOC), 3 MG/M 3
(RESPIRABLE DUST, PARTICULATES NOT OTHERWISE CLASSIFIED-PNOC), 10 MG/M3
(INHALABLE PARTICULATE, MEASURED AS AMORPHOUS SILICA), 3 MG/M3 (RESPIRABLE
PARTICULATE, MEASURED AS AMORPHOUS SILICA).
=======================================================
Ecological Information
=======================================================
Ecological: ENVIRONMENTAL IMPACT RATING (0-4): NOT AVAILABLE. ACUTE AQUATIC
TOXICITY: NOT AVAILABLE. DEGRADABILITY: NOT AVAILABLE. LOG BIOCONCENTRATION
FACTOR (BCF): NOT AVAILABLE.LOG OCTANOL / WATER PARTITI ON COEFFICIENT: NOT
AVAILABLE.
=======================================================
=======================================================
Transport Information: THIS PRODUCT IS NOT REGULATED AS A HAZARDOUS MATERIAL BY
THE DOT. WASTE DISPOSAL METHOD (CONT): DETERMINE ATE THE TIME OF
DISPOSAL WHETHER A METERIAL HAS BEEN CONTAMINATED AND SHOULD BE CLASSIF IED
AS A HAZARDOUS WASTE. DISPOSAL IS SUBJECT TO LOCAL, STATE AND FEDERAL
REGULATIONS.
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: NONE OF THE PRODUCT INGREDIENTS ARE LISTED AS
EMERGENCY PLANNING AND COMMUNITY RIGHT-TO-KNOW ACT (EPCRA) - SECTION 302:
EXTREMELY HAZARDOUS SUBSTANCES (ERS). NONE OF THE PRODUCT COMPONENTS ARE
PRESEN T ABOVE THE MINIMUM QUANTITES OF LISTED CHEMICALS IN EPCRA SECTION 313
SUPPLIER NOTIFICATION.
Federal Regulatory Information: ALL INGREDIENTS ARE REGISTERED UNDER THE TOXIC
SUBSTANCES CONTROL ACT (TSCA) OR UNDER POLYMER EXEMPTION. ALL INGREDIENTS
ARE EXEMPT, REGISTERED OR CONSIDERED REGISTERED (POLYMERS) UNDER THE EUROPEAN
INVENTORY OF EXISTING COMMERCIAL CHEMICAL SUBSTANCES (EINECS).
State Regulatory Information: CALIFORNIA PROPOSITION 65: THIS PRODUCT CONTAINS
NO KNOWN MATERIALS AT LEVELS WHICH THE STATE OF CALIFORNIA HAS FOUND TO CAUSE
CANCER, BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
=======================================================
Other Information
=======================================================
Other Information: CHEMICAL FAMILY: CARTRIDGE CONTAINS TONER.PRODUCT USE:
OPTRA COLOR 1200 PRINTERS. LEXMARK HAS DETERMINED THAT MATERIAL SAFETY
DATA SHEETS ARE NOT REQUIRED FOR PRINT CARTRIDGES. FOR CUSTOMER CO NVENIENCE,
LEXMARK PROVIDES PRODUCT INFORMATION IN THIS FAMILIAR FORMAT.
(PHYSICAL/CHEMICAL CONT) PRESSURIZED: NO. PARTICLE SIZE: D50 8.5UM. SOFTENING
POINT: 117-123C. SPILL RELEASE PROCEDURE S (CONT): PERMEATED SWEEPING
COMPOUND MAY ASSIST IN CLEAN UP OF TONER SPILLED ON NONPOROUS SURFACES.
=======================================================
HAZCOM Label
=======================================================
Product ID: MAGENTA TONER CARTRIDGE, 12A1451
Cage: 05487
Company Name: LEXMARK INTL INC
Street: 740 WEST NEW CIRCLE RD
Zipcode: 40550-1876
Label Required IND: Y
Date Of Label Review: 11/01/2001
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE: LOW INHALATION TOXICITY. EXPOSURE TO HIGH
CONCENTRATIONS OF ANY DUST MAY CAUSE MINIMAL RESPIRATORY TRACT IRRITATION.
NOT A SKIN IRRITANT, HAS LOW DERMAL TOXICITY. DUST MAY ACT AS A MECHANICAL E
YE IRRITANT. HAS LOW ORAL TOXICITY. CHRONIC: RARE INDIVIDUALS MAY NOTE SKIN
RASH UPON REPEATED OR PROLONGED CONTACT.
=======================================================
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:3705S ISOCYANATE ACTIVATORS,HARDNERS & ADDITIVES
Preparer's Name:T R LOUER
CAGE:23027
CAGE:90227
CAGE:23027
============= Composition/Information on Ingredients =============
Ingred Name:BUTYL ACETATE (N-BUTYL ACETATE) *96-3*
CAS:123-86-4
RTECS #:AF7350000
Other REC Limits:150 PPM
OSHA PEL:710 MG/CUM
ACGIH TLV:713 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ALIPHATIC POLYISOCYANATE, HEXAMETHYLENE DIISOCYANATE
POLYMER *96-3*
CAS:3779-63-3
Ingred Name:VOLATILE ORGANIC CONTENT: 0.4 LBS/GAL
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NOSE & THROAT IRRITATION.
ISOCYANATES MAY CAUSE RESPIRATORY SENSITIZATION & MAY DECREASE IN
LUNG FUNCTIONS WHICH MAY BE PERMANENT. REPEATED/PROLONGED
OVEREXPOSURE TO SOLVENTS MAY CAUSE PER MANENT BRAIN & NERVOUS
SYSTEM DAMAGE. SKIN: IRRITATION, DERMATITIS. EYES: IRRITATION,
BURNING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, EYE WATERING, HEADACHES, NAUSEA,
DIZZINESS, LOSS OF COORDINATION, BREATHING PROBLEMS, DISCOMFORT, GI
DISTRESS
======================= First Aid Measures =======================
First Aid:INGESTION: CALL A PHYSICIAN IMMEDIATELY & HAVE NAMES OF
INGREDIENTS AVAILABLE. INHALATION: REMOVE TO FRESH AIR. SKIN: WASH
W/SOAP & WATER. EYES: WASH W/WATER FOR 15 MINS. OBTAIN MEDICAL
ATTENTION IN A LL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:<100F
Lower Limits:0.8
Upper Limits:11.5
Extinguishing Media:WATER SPRAY, FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING W/SCBA. WATER
FROM FOG NOZZLES MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT
PRESSURE BUILD UP.
Unusual Fire/Explosion Hazard:WHEN HEATED ABOVE FLASH POINT, EMITS
FLAMMABLE VAPORS WHICH, WHEN MIXED W/AIR, CAN BURN/EXPLODE. FINE
MISTS/SPRAYS MAY BE FLAMMABLE AT TEMP 120F. DON'T SAND, FLAME CUT,
BRAZE/WELD DRY COATING W/O NIOSH/MSHA APPROVED
RESPIRATOR/APPROPRIATE VENTILATION. DON'T BREATHE VAPOR S/MISTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A POSITIVE PRESSURE SUPPLIED AIR RESPIRATOR
WHILE MIXING ACTIVATOR W/PAINT/CLEAR ENAMEL, DURING APPLICATION &
UNTIL VAPORS & SPRAY MISTS ARE EXHAUSTED. DON'T PERMIT ANYONE W/O
PROTECTION IN THE P AINTING AREA.
Ventilation:SUFFICIENT VENTILATION IN VOLUME & PATTERN TO KEEP
CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Other Protective Equipment:COVERALLS
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE
EATING/SMOKING.
Supplemental Safety and Health
%VOLATILE BY VOLUME: 6.4-80.9%. SPILLS CONT'D: POUR LIQUID
DECONTAMINATE SOLUTION OVER SPILL & ALLOW TO SIT 10 MINS, MINIMUM.
DECONTAMINATION SOLUTION: 20% SURFACTANT, 80% WATER, 0-10% AMMONIA,
2-5% D ETERGENT, BALANCE WATER. PRESSURE CAN BE GENERATED. DON'T
SEAL CONTAINER. AFTER 48 HRS, IT MAY BE SEALED & DISPOSED OF.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:169-882F
Vapor Density:>1
Evaporation Rate & Reference:(ETHER =1): <1
Solubility in Water:MISCIBLE
Percent Volatiles by Volume:(SUPP)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, AMINES, METAL SALTS
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, TEMP >120F.
Hazardous Decomposition Products:CO, CO2, SMOKE
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T ALLOW MATERIAL TO CONTAMINATE GROUND WATER
SYSTEMS. INCINERATE ABSORBED MATERIAL IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T INCINERATE IN CLOSED CONTAINERS. FLAMMABLE
LIQUID, UN1263.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:PR-1664, PART A
Kit Part:Y
Preparer's Name:J.R.W.
CAGE:DO563
CAGE:83574
CAGE:DO563
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 55%
OSHA PEL:200 PPM;300 PPM STEL
ACGIH TLV:200 PPM;300 PPM STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ANILINE, 4,4'-METHYLENEDI-; (4,4'-METHYLENE DIANILINE)
(MDA)
CAS:101-77-9
RTECS #:BY5425000
Fraction by Wt: 40%
ACGIH TLV:0.1 PPM, S
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:FORMALDEHYDE, POLYMER WITH BENZENAMINE; (POLYMETHYLENE
POLYPHENYLENE POLYAMINE)
CAS:25214-70-4
RTECS #:TQ0600000
Fraction by Wt: 5%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION. CAUSES
TEARING AT LOW LEVELS. SKIN: LOCAL IRRITATION. CAN CAUSE ALLERGIC
SKIN RASH IN SENSITIZED INDIVIDUALS. CAUSES FEVER, CHILLS, LOSS OF
APPETITE, ABDOMINAL PAIN, VOMITINGAND JAUNDICED APPEARANCE.
INHAL: IRRITATION OF MUC MEMB, THROAT AND LUNGS. CAUSES FEVER,
CHILLS, LOSS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:METHYLENE DIANILINE (4,4): IARC GRP 2B,
NTP GRP 2, ACGIH GRP A2.
Effects of Overexposure:HLTH HAZ: OF APPETITE, ABDOMINAL PAIN, VOMITING
AND JAUNDICED APPEARANCE. INGEST: CAUSES FEVER, CHILLS, LOSS OF
APPETITE, ABDOMINAL PAIN AND JAUNDICED APPEARANCE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LUKE WARM WATER FOR 15 MINUTES. IF SYMPTOMS
PERSIST, CONSULT MD. SKIN: WASH WITH SOAP AND WATER. IF SYMPTOMS
PERSIST, CONSULT MD. INHAL: REMOVE TO FRESH AIR. IF SYMPTOMS ARE
PRESENT C ONSULT MD. INGEST: CONSULT MD.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:22.0F,-5.6C
Lower Limits:1.8%
Upper Limits:10% (MEK)
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . USE WATER TO COOL HEAT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:HIGH TEMPERATURES MAY CAUSE PRESSURE
BUILDUP IN CLOSED CONTAINERS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. WEAR NIOSH/MSHA
APPROVED AIR-SUPPLIED RESPIRATOR FOR MAJOR UNVENTILATED SPILL.
COVER WITH ABSORBANT. SCOOP INTO CONTAINERS. CLEAN-UP RESIDUE WITH
1,1,1- TRICHLOROETHANE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:AVOID INGESTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:GEN VENT TO MAINTAIN VAPS BELOW PEL. WHEN APPLYING IN
CONFINED AREAS/IN OTHER CIRCUMSTANCES LIKELY TO (SUPP DATA)
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
SMOKING OR EATING.
Supplemental Safety and Health
KEY1: F3. THIS ENTRY DESCRIBES PART A OF A TWO PART KIT. SEE THIS SAME
NSN, P/N IND B, FOR PART B DATA. VENT: PRODUCE AIRBORNE LEVELS OF
SOLVENT IN EXCESS OF PEL, USE A NIOSH/MSHA APPROVED ORGANIC VAP OR
CARTRIDGE RESPIRATOR OR AIR-SUPPLIEDRESPIRATOR.
================== Physical/Chemical Properties ==================
HCC:F3
Vapor Density:2.5 (MEK)
Spec Gravity:0.90
Evaporation Rate & Reference:3.8 (MEK)
Solubility in Water:SLIGHT
Appearance and Odor:LIGHT YELLOW TO AMBER LIQUID
Percent Volatiles by Volume:60
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OXIDES OF CARBON AND NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:EPA WASTE NO. D-001 AND D-035. DISPOSE OF
SPILLAGE IN COMPLIANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:WET OR DRY SILVER-ZINC BATTERY
CAGE:87362
CAGE:87362
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM HYDROXIDE (SARA III) (ELECTROLYTE)
CAS:1310-58-3
RTECS #:TT2100000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C, 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ZINC (SARA III)
CAS:7440-66-6
RTECS #:ZG8600000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG ZNO/M3
ACGIH TLV:10 MG ZNO/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SILVER (SARA III)
CAS:7440-22-4
RTECS #:VW3500000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.01 MG/M3
ACGIH TLV:0.1 MG/M3; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:MERCURIC OXIDE (SARA III)
CAS:21908-53-2
RTECS #:OW8750000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG HG/M3;SKIN;C
ACGIH TLV:0.1 MG HG/M3; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION OF FUMES OF BURNING
BATTERY MAY CAUSE RESPIRATORY IRRITATION. ABSORPTION OF MERCURY MAY
CAUSE CENTRAL NERVOUS SYTEM DAMAGE. ABSORPTION OF SILVER MAY CAUSE
ARGYRIA. CONTACT WITH ELECT ROLYTE MAY CAUSE BURNS TO SKIN AND
EYES.CHRONIC: PROLONGED OR REPEATED EXPOSURE MAY CAUSE MERCURY
POISONING/ARGYRIA.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN BY
NTP, IARC, OSHA
Effects of Overexposure:INHALED: COUGHING, SNEEZING, SHORTNESS OF
BREATH, LOSS OF MEMEORY, TREMORS. EYES: BURNS, PAIN, TEARING. SKIN:
REDNESS, PAIN, BURNS. ABSORPTION; TREMORS, MEMORY LOSS, GREY-BLUE
PATCHES OF SKIN.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALED: MOVE TO FRESH AIR. GET MEDICAL ATTENTION IF SYMPTOMS
DEVELOP. EYES: FLUSH WITH LOTS OF WATER FOR 15 MINUTES, HOLD LIDS
OPEN. SEE DOCTOR. SKIN: WASH WITH LOTS OF SOAP AND WATER. INGESTED:
GET IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:INTENSE HEAT AND ACRID SMOKE FROM BURNING
METAL AND PLASTIC COMPONENTS.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN ELECTROLYTE IF CASE BROKEN. VENTILATE
AREA. NEUTRALIZE ELECTROLYTE WITH BORIC ACID. DO NOT FLUSH TO
SEWER. COLLECT ALL SPILLAGE AND DEBRIS FOR PROPER DISPOSAL.
Neutralizing Agent:BORIC ACID
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. AVOID
SHORT CIRCUITING TERMINALS OF WET CELLS AND BATTERIES. AVOID
EXPOSURE TO INTENSE HEAT OR FIRE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION OR LOCAL EXHAUST TO
MAINTAIN AIR CONTAMINANT LEVELS BELOW REGULATORY LIMITS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER. HMIS: EYE
WASH RECOMMENDED.
Work Hygienic Practices:WASH THOROUGHLY AFTER USE AND BEFORE EATING
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
HMIS TECHNICIAN UNSURE IF BATTERY IS DRY OR WET DLSC-TIR SAYS
EITHER/OR; CTDF SAYS DRY. PER MANUFACTURER- BATTERY CONTAINS 17
TROY OUNCES SILVER PER CELL AND 976 ML OF ELECTROLYTE.
================== Physical/Chemical Properties ==================
HCC:B1
Appearance and Odor:NO ODOR; BATTERY
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS AND SOLVENTS
Stability Condition to Avoid:SHORT CIRCUITING POSITIVE AND NEGATIVE
TERMINALS
Hazardous Decomposition Products:MERCURIC OXIDE FUMES, HYDROGEN GAS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. CONTAINS SILVER, RECYCLE IAW REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:VARSOL I
CAGE:MO082
CAGE:MO082
CAGE:29700
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM HYDROCARBONS
Fraction by Wt: 100%
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
Effects of Overexposure:DIZZINESS,HEADACHE,UNCONSCIOUSNESS.PROLONGED OR
REPEATED SKIN CONTACT WILL DRY OR DEFAT SKIN
======================= First Aid Measures =======================
First Aid:INHALATION-MOVE TO FRESH AIR.CALL DOCTOR.GIVE OXYGEN IF
BREATHING IRREGULAR.INGESTION-DO NOT INDUCE VOMIT. CALL
DOCTOR.SKIN-REMOVE SOILED CLOTHES.WASH WITH SOAP & WARM
WATER.EYES-FLUSH WITH WATER FOR 15 MIN OR UNTIL IRRITATION
SUBSIDES.
===================== Fire Fighting Measures =====================
Flash Point:108F (42C) TCC
Lower Limits:0.9
Upper Limits:6.0
Extinguishing Media:FOAM,DRY CHEMICAL,CARBON DIODE,WATER FOG OR SPRAY
Fire Fighting Procedures:USE AIR SUPP EQUIP IN CLOSE AREAS.COOL EXPOSED
CONT W/WATER
Unusual Fire/Explosion Hazard:DO NOT MIX OR STORE WITH STRONG OXIDIZERS
LIKE LIQUID CHLORINE OR CONCENTRATED OXYGEN
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES.KEEP PEOPLE
AWAY.RECOVER FREE LIQUID.ABSORB WITH SAN,EARTH SAWDUST ETC AVOID
BREATHING VAPOR.VENTILATE AREA. OPEN WINDOWS.KEEP OUT OF
SEWERS,WATERCOURSES ETC. OR EXTENSIVE LANDAREAS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE.DO NOT HANDLE OR STORE NEAR HEAT,SPARKS,FLAME OR
OXIDIZERS.PROVIDE VENTILATION EQUAL TO OUTDOORS
Other Precautions:AVOID BREATHING VAPORS.AVOID PROLONGED OR REPEATED
SKIN CONTCT.REMOVE CONTAMINATED CLOTHING,LAUNDER BEFORE REUSE DRY
SOILED SHOES BEFORE REUSE.WASH SKIN THOROUGHLY WITH SOAP & WATER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:HYDROCABON VAPOR CANNISTER OR SUPPLIED-AIR
RESPIRATOR
Ventilation:LOCAL-FACE VELOCITY >60 FPM.USE EXPLOSION PROOF FANS
Other Protective Equipment:CHEMICAL RESISTANT APRON OR OTHER CLOTHING
Supplemental Safety and Health
TLV OF 100 PPM ESTABLISHED USING STODDARD SOLVENT FOR COMPARISON.EXXON
STUDIES HAVE FOUND KIDNEY DAMAGE IN RATS AT THIS CONCENTRATION.
FURTHER STUDIES ARE UNDER WAY TO DETERMINE TLV
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:=156.1C, 313.F
B.P. Text:313-400F
Vapor Pres:104
Vapor Density:4.8
Spec Gravity:0.79
Evaporation Rate & Reference:<0.1 BUTYL ACETATE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WATER WHITE LIQUID.MINERAL SPIRITS ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS LIKE LIQ CHLORINE,CONC O*2,HYPOCHLORITES
Hazardous Decomposition Products:FUMES,SMOKE,CARBON MONOXIDE IN CASE OF
INCOMPLETE COMBUSTION
==================== Disposal Considerations ====================
Waste Disposal Methods:ASSURE CONFORMITY WITH APPLICABLE DISPOSAL
REGULATIONS.PLACE ABSORBED MATERIAL IN CONTAINERS SUITABLE FOR
SHIPMENT TO DISPOSAL AREA DISPOSE OF IN APPROVED FACILITY.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:383 GREEN ZENTHANE, 08605GUA-GD
CAGE:09225
CAGE:09225
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ISOAMYL KETONE
CAS:110-12-3
RTECS #:MP3850000
Fraction by Wt: 20-30%
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9293
Ingred Name:SILICA
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: <.5%
OSHA PEL:1.300 PPM; 20 MPPCF
ACGIH TLV:4.075 PPM; 10 MG/M3
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 20-30%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: .5-5.0%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:AROMATIC 100
CAS:64742-95-6
Fraction by Wt: .5-5.0%
Other REC Limits:50 PPM=MFR'S LIMIT
Ingred Name:COBALT (SARA III)
CAS:7440-48-4
RTECS #:GF8750000
Fraction by Wt: <.5%
OSHA PEL:0.1 MG/M3;AS CO
ACGIH TLV:0.05 MG/M3;DUST 9293
Ingred Name:CHROMIUM (SARA III)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 5-10%
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: .5-5.0%
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:1,6-DIISOCYANATOHEXANE (HEXAMETHYLENE DIISOCYANATE)
CAS:822-06-0
RTECS #:MO1740000
Fraction by Wt: <.05%
Other REC Limits:0.02 PPM=MFR'S
ACGIH TLV:0.005 PPM; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:HOMOPOLYMER OF HEXAMETHYLENE DIISOCYANATE
CAS:28182-81-2
RTECS #:NQ9170000
Fraction by Wt: 20-30%
Other REC Limits:1 MG/M3=MFR'S LIMIT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:IRRITATION TO SKIN, EYES, RESPIRATORY
TRACT. RESPIRATORY SENSITIZATION CHARACTERIZED BY ASTHMA-LIKE
SYMPTOMS AND/OR SKIN SENSITIZATION-ALLERGIC DERMATITIS. SOME
REPORTS ASSOC REPEAT/PROLONG CONTACT W/ TRIVALENT CHROME TO
DERMATITIS. REPORTSASSOC REPEAT/PROLONG OVEREXPOS TO SOLVENTS
W/PERM BRAIN/NERVOUS SYSTEM DAMAGE.
Effects of Overexposure:WATERING EYES, DRYNESS OF THROAT, COUGHING,
HEADACHE, TIGHTNESS IN CHEST OR BURNING SENSATION. HEADACHE,
DIZZINESS OR NAUSEA MAY BE EXPERIENCED BY SOME AS A RESULT OF
EXPOSURE TO SOLVENTS. ALLERGIC DE RMATITIS MAY INCLUDE RASH,
ITCHING, HIVES AND SWELLING OF EXTREMITIES. AVOID CONTACT WITH
EYES, SKIN AND CLOTHING.
Medical Cond Aggravated by Exposure:ASTHMA AND OTHER RESPIRATORY
AILMENTS; CHEMICAL SENSITIZATION.
======================= First Aid Measures =======================
First Aid:VAPORS: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM
AND QUIET. NOTIFY A PHYSICIAN. EYES: FLUSH IMMEDIATELY WITH LARGE
AMOUNTS OF RUNNING WATER FOR AT LEAST 15 MINUTES. TAKE TO A
PHYSICIAN FOR M EDICAL TREATMENT. SKIN: WASH AFFECTED AREAS WITH
SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. CONSULT A PHYSICIAN.
INGESTION: IF SWALLOWED, CALL A PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:78.0F,25.6C
Lower Limits:1.0
Extinguishing Media:FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT WITH SCBA. DURING A
FIRE, IRRITATING AND HIGHLY TOXIC GASES AND SMOKE ARE PRESENT FROM
THE DECOMPOSITION/COMBUSTION PRODUCTS.
Unusual Fire/Explosion Hazard:KEEP CLOSED TIGHT,FROM IGNITE
SOURCE.CLOSED CNTNR EXPLODE W/HEAT/BURST WHEN CONTAM W/WTR.DON'T
APPLY TO HOT SRFC.NEVER WELD/CUT TORCH ON/NEAR DRUM/IGNITE EXPLOS
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE NON-ESSENTIAL PERSONNEL. REMOVE
IGNITE SOURCE. VENT AREA. AVOID BREATH VAPOR. COVER W/INERT ABSORB.
POUR LIQ DECONTAM OVER SPILL-LET REACT-10 MIN, COLLECT MAT'L IN
OPEN CNTNRS-ADD MORE DECONT AM SOLUT'N. REMOVE CNTNR TO SAFE
PLACE-LOOSELY *
Neutralizing Agent:N/K*COVER. WASH DOWN AREA WITH DECONTAMINANT &
FLUSH SPILL AREA WITH WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F/BELOW 32F.
STORE LG AMT IN BLDGS THAT COMPLY W/OSHA 1910.106. KEEP FROM IGNITE
SOURCE. KEEP TIGHTLY CLOSED FROM MOISTURE.
Other Precautions:DON'T TAKE INTERNALLY. GROUND CNTNR WHEN POURING.
AVOID FREE FALL OF LIQ IN EXCESS OF A FEW INCHES. USE W/ADEQUATE
VENT/RESPIRATORY EQUIP. EMPTY CNTNR RETAIN HZDS RESIDUE/EXPLOSIVE
VAPOR. FOLLOW PRECA UTIONS UNTIL THOROUGHLY CLEAN/DESTROYED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SURGEON GENERAL REQUIRES AIRLINE RESPIRATORS BE
USED UNLESS AIR SAMPLE SHOWS EXPOS BELOW OSHA LIMITS. THEN, EITHER
CHEMICAL CARTRIDGE RESPIRATORS OR AIRLINE RESPIRATORS REQUIRED. USE
SAME PRECAUTIONS DURING MIXING OR OPERATION W/PAINT FUMES
Ventilation:GENERAL DILUTION/LOCAL EXHAUST VENT IN VOLUME/PATTERN TO
KEEP AIR CONTAMINANT CONC BELOW CURRENT OSHA SFTY/HLTH REQUIR.
Other Protective Equipment:WEAR PROTECTIVE CLOTHING TO KEEP SKIN
CONTACT AT A MINIMUM.
Work Hygienic Practices:WASH AFTER HANDLING. WASH HANDS AND ANY EXPOSED
SKIN THOROUGHLY BEFORE EATING OR SMOKING. SMOKE IN SMOKING AREAS
ONLY.
Supplemental Safety and Health
IF MOISTURE ENTERS CONTAINER, PRESSURE CAN BUILD UP DUE TO REACTION
PRODUCING CO2 WHICH CAN CAUSE SEALED CONTAINER TO PRESSURIZE AND
BURST. DO NOT RESEAL IF CONTAMINATION IS SUSPECTED.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:244 TO 350F
Vapor Pres:8.00
Vapor Density:>AIR
Evaporation Rate & Reference:EQUAL TO BUTYL ACETATE
Solubility in Water:REACTS WITH WATER
Appearance and Odor:OPAQUE LIQUID, SOLVENT ODOR
Percent Volatiles by Volume:51.08
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, ALCOHOLS, AMINES.
Stability Condition to Avoid:WATER CONTAMINATION.
Hazardous Decomposition Products:BY FIRE: CO2, CO, OXIDES OF NITROGEN,
TRACES OF HYDROGEN CYANIDE, HEXAMETHYLENE DIISOCYANATE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL ENVIRONMENTAL CONTROL REGULATIONS. DECONTAMINATE CONTAINERS
PRIOR TO DISPOSAL.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SALICYLATE CALIBRATOR
CAGE:63404
CAGE:63404
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM SALICYLATE
CAS:54-21-7
RTECS #:VO5075000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: > 99%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RAT LD50: 1600 MG/KG SODIUM SALICYE
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION OF MIST OR AEROSOL COULD
CAUSE IRRITATION OF UPPER RESPIRATORY SYSTEM. HOWEVER, THIS IS NOT
A LIKELY ROUTE OF EXPOSURE. SKIN CONTACT MAY CAUSE IRRITATION,
RASH. MAY BE HARMFUL BY ABSORPTION . EYE CONTACT MAY CAUSE
IRRITATION. INGESTION MAY CAUSE IRRITATION OF MOUTH, THROAT AND GI
TRACT.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:RESPIRATORY IRRITATION, EYE IRRITATION, SKIN
IRRITATION, SKIN RASH, GI UPSET, DIZZINESS, RINGING IN EARS,
ASTHMA, SWELLING, HIVES.
Medical Cond Aggravated by Exposure:INDIVIDUALS SENSITIVE TO ASPIRIN OR
IBUPROFAN MAY EXPERIENCE ASTHMA, SWELLING, HIVES OR LIFE
THREATENING SHOCK FROM INGESTION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH WITH SOAP AND WATER. IF IRRITATION PERSISTS, GET MEDICAL
ATTENTION. IN HALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. GET
MEDICAL ATTENTION. INGESTION: IMMEDIATELY GIVE TWO GLASSES OF WATER
AND INDUCE VOMITING. GET A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:NONFLAMMABLE. USE MEDIA SUITABLE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:EVACUATE PERSONNEL TO A SAFE AREA. KEEP
PERSONNEL REMOVED AND UPWIND. WEAR SELF-CONTAINED BREATHING
APPARATUS. WEAR FULL PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROPER PERSONAL PROTECTIVE EQUIPMENT.
RECOVER UNDAMAGED AND MINIMALLY CONTAMINATED MATERIAL FOR REUSE OR
RECLAMATION. COLLECT REMAINDER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT MIX WITH INCOMPATIBLES. DO NOT
CONSUME FOOD, DRINK OR TOBACCO IN AREAS WHERE THEY MAY BECOME
CONTAMINATED WITH THIS MATERIAL.
Other Precautions:AVOID SKIN CONTACT. LAUNDER CONTAMINATED CLOTHING
BEFORE REUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED.
Ventilation:LOCAL EXHAUST AND MECHANICAL (GENERAL) VENTILATION TO
MAINTAIN EXPOSURE LEVELS.
Other Protective Equipment:PROTECTIVE CLOTHING AS REQUIRED TO AVOID
SKIN CONTACT. AN EMERGENCY EYE WASH STATION AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
AVOID BREATHING VAPORS OR MIST. AVOID CONTACT WITH EYES, SKIN OR
CLOTHING.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NOT GIVEN
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:NOT GIVEN
Spec Gravity:NOT GIVEN
pH:6-7
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:SOLUBLE
Appearance and Odor:ODORLESS LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:HEAT, OPEN FLAME, LIGHT
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER
OR LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:OLIVE DRAB HIGH SOLIDS HEAT RESISTANT COATING #02366GML
Preparer's Name:JANE FREEMAN
CAGE:09225
CAGE:09225
============= Composition/Information on Ingredients =============
Ingred Name:BUTYL ALCOHOL SOLVENT (SARA III)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 3.442%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:50 PPM (CEILING)
ACGIH TLV:50 PPM (CEILING)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TITANIUM DIOXIDE PIGMENT
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 10-15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:TALC PIGMENT
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:NICKEL COMPOUNDS (INSOLUBLE COMPOUNDS) (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 0.658%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:ISOBUTYL ALCOHOL SOLVENT (SARA III)
CAS:78-83-1
RTECS #:NP9625000
Fraction by Wt: 1.159%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:50 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL BENZENE SOLVENT (SARA III)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 2.044%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM;STEL 125 PPM
ACGIH TLV:100 PPM;STEL 125 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE SOLVENT (SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 18.617%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM;STEL 150 PPM
ACGIH TLV:100 PPM;STEL 150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SILICEOUS EXTENDER PIGMENT
CAS:66402-68-4
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:MICA PIGMENT
CAS:12001-26-2
RTECS #:VV8760000
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:20 MPPCF
ACGIH TLV:3 MG/M3 (RESP DUST)
Ingred Name:BARIUM COMPOUND
Fraction by Wt: 1.937%
Other REC Limits:NUISANCE DUST
Ingred Name:FRITS
Fraction by Wt: 15-20%
Other REC Limits:NUISANCE DUST
Ingred Name:AROMATIC HYDROCARBONS (MIXTURE OF C8'S TO C10'S)
CAS:64742-95-6
Fraction by Wt: 1.846%
Other REC Limits:MFR'S LIMIT: 100 PPM
Ingred Name:TRIVALIENT CHROME (INSOLUBLE) (SARA 313) (CERCLA)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 7.079%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.5 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL: ANESTHETIC. RESPIRATORY TRACT
IRRITATION OR ACUTE NERVOUS SYSTEM DEPRESSION (HEADACHE, DIZZINESS,
STAGGERING, CONFUSION OR COMA). SKIN: IRRITATION, DEFATTING,
DERMATITIS. EYE: IRRITATION. CHRON IC: BRAIN/NS/LIVER/KIDNEY
DAMAGE, DERMATITIS, DELAYED RESPIRATORY SYSTEM EFFECTS.
Explanation of Carcinogenicity:IARC & NTP LIST NICKEL AS PROBABLY
CARCINOGENIC TO HUMAN.
Medical Cond Aggravated by Exposure:ASTHMA AND OTHER RESPIRATORY
AILMENTS; CHEMICAL SENSITIZATION.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM &
QUIET. NOTIFY A PHYSICIAN. EYES: FLUSH IMMEDIATELY WITH LARGE
AMOUNTS OF RUNNING WATER FOR AT LEAST 15 MINUTES. LIFT LIDS. TAKE
TO PHYSICIAN FOR MEDICAL TREATMENT. SKIN: WASH WITHSOAP & WATER.
REMOVE CONTAM CLOTHES, WASH BEFORE REUSE, CALL DR. INGEST: CALL
DR/POISON CONTROL CENTER IMMED.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:81.0F,27.2C
Autoignition Temp:Autoignition Temp Text:NA
Lower Limits:1.0
Upper Limits:11.2
Extinguishing Media:FOAM, DRY CHEMICAL, CO2
Fire Fighting Procedures:WEAR PROTECT EQUIP INCLUDING SCBA. WATER MAY
BE INEFFECTIVE, USE WATER (FOG NOZZLES PREFERRED) COOL CLOSED CNTNR
TO PREVENT PRESSURE BLDUP,AUTOIGNITN,EXPLOSION.
Unusual Fire/Explosion Hazard:KEEP CONTAINER TIGHTLY CLOSED. KEEP FROM
HEAT/IGNIT SOURCE. CLOSED CNTNR MAY EXPLODE W/HEAT. DON'T APPLY TO
HOT SRFCS. NEVER USE WELD/CUT TORCH ON/NEAR DRUM.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE
AREA. USE APPROPRIATE PROTECTIVE EQUIPMENT. AVIOD BREATHING
VAPORS/SKIN CONTACT. PREVENT ENTRY TO DRAINS/SEWERS/WATERWAYS.
NOTIFY AUTHORITIES. CONTAIN & REMOV E WITH INERT ABSORBENT AND
NONSPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:DONT STORE @>120F. LARGE AMTS IN
BUILDINGS DESIGNED (OSHA 1910.106). NO IGNITS. KEEP
CLOSED/UPRIGHT/TIGHT WHEN NOT IN USE. EMPTY CNTNR HAZARDOUS.
Other Precautions:SOAK SOILED RAGS/WASTES IN H2O FILLED CLOSED CNTNR.
USE W/ADEQUATE VENT, AVOID VAPOR BREATHING/SKIN CONTACT,
GROUND/BOND WHEN TRANSFERRING, AVOID FREEFALL OF LIQ >FEW INCHES,
USE SPARKPROOF TOOLS/EXPL OSION PROOF EQUIPMENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:OUTDOOR/SANDING/GRINDING: NIOSH MECHANICAL
FILTER RESPRTR. CONFINED AREA: NIOSH AIR SUPPLIED RESPIRATOR/HOOD.
AIR MONITORING MAY BE REQUIRED.
Ventilation:GENERAL DILUTION/LOCAL EXHAUST TO KEEP BELOW PEL/TLV.
Other Protective Equipment:APPROPRIATE TO PREVENT PROLONGED SKIN
CONTACT.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR SMOKING. SMOKE IN
DESIGNATED SMOKING AREAS ONLY.
Supplemental Safety and Health
MORE INFORMATION ON FILE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:220 TO 418F
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:9.00 @ 68F
Vapor Density:> AIR
Spec Gravity:1.41
pH:NA
VOC Grams/Liter:3.38
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OPAQUE LIQUID, SOLVENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO DECOMPOSITION AS IN WELDING. MAY CONTAIN CARBON MONOXIDE
& CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:RECYCLE OR INCINERATE IN ACCORDANCE WITH LOCAL,
STATE, & FEDERAL REGULATIONS.
======================= Other Information =======================
======================================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:PAC 127
CAGE:56923
CAGE:56923
============= Composition/Information on Ingredients =============
Ingred Name:TUNGSTEN
CAS:7440-33-7
RTECS #:YO7175000
Fraction by Wt: 83%
OSHA PEL:5 MG/M3/ 10 STEL
ACGIH TLV:5 MG/M3/10 STEL;9192
Ingred Name:COBALT (SARA III)
CAS:7440-48-4
RTECS #:GF8750000
Fraction by Wt: 12%
Other REC Limits:0.05 PPM
OSHA PEL:0.1 MG/M3;AS CO
ACGIH TLV:0.05 MG/M3;DUST 9293
Ingred Name:GRAPHITE, SYNTHETIC
CAS:7440-44-0
RTECS #:FF5250100
Fraction by Wt: 5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: UPPER RESPIRATORY TRACT
IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: UPPER RESPIRATORY TRACT IRRITATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CLASS D (E.G. MET-L-X POWDER)
Fire Fighting Procedures:AVOID BLOWING OF POWDER W/PRESSURIZED
EXTINGUISHERS.
================== Accidental Release Measures ==================
Spill Release Procedures:USE NORMAL PRECAUTIONS FOR HANDLING DUSTY
MATERIALS. WEAR PROTECTIVE RESPIRATORY EQUIPMENT.
======================Handling and Storage ======================
Handling and Storage Precautions:USE NORMAL PRECAUTIONS FOR HANDLING
DUSTY MATERIALS. AVOID IGNITION. AVOID BLOWING OF POWDER
W/PRESSURIZED EXTINGUISHERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE ANTI-DUST RESPIRATOR.
Ventilation:USE NORMAL EQUIPMENT. LOCAL EXHAUST/GENERAL: RECOMMENDED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:10,800F
Vapor Pres:1
Vapor Density:>AIR
Solubility in Water:NEGLIGLIBLE
Appearance and Odor:GRAY POWDER W/NO ODOR
Percent Volatiles by Volume:0%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:IGNITION SOURCES
Hazardous Decomposition Products:CO & CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:5102, SOLID COLORS AUTOMOTIVE TOUCH-UP
CAGE:9P972
CAGE:86142
CAGE:9P972
============= Composition/Information on Ingredients =============
Ingred Name:ING 4: USED TO EFFECTIVELY MINIMIZE EMPLOYEE EXPOSURE: LOC
EXHST VENT, ENCLOSED SYS DESIGN, PROCESS ISOLATION (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: & REMOTE CONTROL IN COMBINATION W/APPROP USE OF
PERSONAL PROTECTIVE EQUIPMENT & PRUDENT WORK PRACTICES. (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: THESE TECHNIQUES MAY NOT NECESSARILY ADDRESS ALL
ISSUES PERTAINING TO YOUR OPERATIONS. WE, THEREFORE, (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: RECOMMEND THAT YOU CONSULT WITH EXPERTS OF YOUR
CHOICE TO DETERMINE WHETHER OR NOT YOUR PROGRAMS ARE ADEQUATE.
RTECS #:9999999ZZ
Ingred Name:2-PENTANONE, 4-METHYL; (METHYL ISOBUTYL KETONE) (SARA III)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 30-50%
OSHA PEL:50 PPM;75 STEL
ACGIH TLV:50 PPM;75 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CYCLOHEXANONE (SARA III)
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: 5-10%
OSHA PEL:25 PPM, S
ACGIH TLV:25 PPM, S
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENE (SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 10-30%
OSHA PEL:100 PPM;150 STEL
ACGIH TLV:100 PPM;150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SUPP DATA: BELOW ACCEPTABLE CRITERIA. ENGINEERING CONTROLS:
THE FOLLOWING EXPOSURE CONTROL TECHNIQUES MAY BE (ING 5)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: SKIN ABSORP/INGEST: NOT
EXPECTED TO BE HARMFUL UNDER NORMAL CONDITIONS OF USE. IF
ACCIDENTALLY SWALLOWED, BURNS OR IRRIT TO MUC MEMBS, ESOPHAGUS OR
GI TRACT CAN RESULT. INHAL:MAY BE HARMFUL IF INHALED. LIQ/VAP MAY
CAUSE IRRIT OF NOSE, THROAT & LUNGS. SKIN: MAY CAUSE IRRIT ON
PROLONGED OR (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: REPEATED CNTCT. EYES: CAUSES IRRIT.
INGRED 1: CAN CAUSE CNS DEPRESS. SIGNS & SMPS MAY INCL HDCH, DIZZ,
NAUS, VOMIT, UNCON & EVEN ASPHY. INGRED 2 & 3: CAN CAUSE LIVER &
KIDNEY DMG. CAN CAUSE CNS DEPRESS. SIGNS & SYMPS MAY INCLUDE HDCH,
DIZZ, NAUS, VOMIT, UNCON & EVEN ASPHY.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN ABSORP:IMMED FLUSH EYE/SKIN W/PLENTY OF WATER FOR @ LST
15 MIN. INGEST: DILUTE BY DRINKING LRG QTYS OF WATER. IMMED CNTCT
POIS CTL CTR/HOSPITAL EMERGENCY ROOM FOR ANY OTHER ADDITIONAL
TREATMENT D IRECTIONS. INHAL:REMOVE TO FRESH AIR. IF NOT BRTHG,
GIVE ARTF RESP, PREFERABLY MOUTH-TO-MOUTH. SKIN:FLUSH WITH WATER.
EYE:IMMED FLUSH W/ PLENTY OF WATER FOR @ LST 15 MIN. EYELIDS SHOULD
BE (SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point:65.3F,18.5C
Extinguishing Media:USE DRY CHEMICAL, "ALCOHOL" FOAM OR CO2. WATER MAY
BE INEFTIVE, BUT SHOULD BE USED TO COOL FIRE-EXPOSED CNTNRS COOL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:KEEP LIQ & VAP AWAY FROM HEAT, SPARKS,
FLAME & OTHER IGNIT SOURCES INCL, BUT NOT LIMITED TO, PILOT LIGHTS,
HEATERS, CIGARETTES, ELECTIC MOTORS AND (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. SOAK UP WITH
ABSORBENT MATERIAL AND REMOVE TO A CHEMICAL DISPOSAL AREA. PREVENT
ENTRY INTO NATURAL BODIES OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. STORE IN A
COOL, DRY PLACE. AVOID PROLONGD OR REPEATED CONTACT WITH EYES, SKIN
OR CLTHG. AVOID BREATHING VAPOR.
Other Precautions:HANDLE IN ACCORDANCE WITH GOOD INDUSTRIAL HYGIENE AND
SAFETY PRACTICES. THESE PRACTICES INCLUDE AVOIDING UNNECESSARY
EXPOSURE AND REMOVAL OF THE MATERIAL FROM EYES, SKIN AND CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE AIR CONTAMS CAN EXCEED ACCEPTABLE
CRITERIA, USE NIOSH/MSHA APPROVED RESP PROT EQUIP. RESPS SHOULD BE
SELECTED BASED ON THE FORM AND CONC OF CONTAMS IN AIR IN ACCORD
W/OSHA 29 CFR 1910.134 OR OTH ER APPLICABLE STDS OR GUIDELINES.
Ventilation:IF AIRBORNE CONTAMS ARE GENERATED WHEN MATL IS HEATED/
HANDLED, SUFFICIENT VENT IN VOL & AIR FLOW PATTERNS (SUPP DATA)
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
% VOL: 58.3-79.0 (WT). EXPLO HAZS: STATIC DISCHARGE. VAP IS HVR/AIR &
MAY SETTLE IN LOW PLACES OR TRAVEL OUTWARD TO A SOURCE OF IGNIT AND
FLASHBACK. FIRST AID PROC: HELD APART DURING IRRIGATION TO INS URE
WATER CNTCT W/ENTIR SURF OF EYES & LIDS. CALL MD. VENT: SHOULD BE
PROVIDED TO KEEP AIR CONTAM CONC LEVELS (ING 4)
================== Physical/Chemical Properties ==================
HCC:F3
Spec Gravity:0.88-1.27
Solubility in Water:SLIGHT
Appearance and Odor:COLORED LIQUID, SOLVENT ODOR.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CO, CO2.
==================== Disposal Considerations ====================
Waste Disposal Methods:RECOVER FREE LIQUID. ABSORB RESIDUE AND DISPOSE
OF ACCORDING TO LOCAL, STATE/PROVINCIAL, AND FEDERAL REQUIREMENTS.
EMPTY CONTAINER: MAY CONTAIN EXPLOSIVE VAPORS. DO NOT CUT, PUNCTURE
OR WELD ON OR NEA RBY.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:OS-120
CAGE:5D028
CAGE:5D028
============= Composition/Information on Ingredients =============
Ingred Name:HEXAMETHYLDISILOXANE
CAS:107-46-0
RTECS #:JM9237000
Fraction by Wt: 89%
Other REC Limits:TWA 200 PPM (MFR)
Ingred Name:PROPYLENE GLYCOL MONOMETHYL ETHER
CAS:107-98-2
RTECS #:UB7700000
Fraction by Wt: 11%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9596
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY &
GI TRACTS. ACUTE- EYE:MAY CAUSE DISCOMFORT. SKIN:REPEATED/PROLONGED
CONTACT MAY CAUSE DEFATTING. INHALE:MAY CAUSE DROWSINESS.
ORAL:SMALL AMOUNTS TRANSFERRED TO M OUTH BY FINGERS SHOULD NOT
INJURE. SWALLOWING LARGE AMOUNTS MAY INJURE SLIGHTLY & CAUSE
DROWSINESS. CHRONIC- DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, NAUSEA, SKIN DRYNESS,
TEARING, BLURRED VISION, ITCHING, DERMATITIS, DISCOMFORT
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION MAY BE
MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:IMMEDIATELY FLUSH WITH
WATER FOR 15 MINUTES. HOLD EYELIDS OPEN. SKIN:WASH WITH SOAP &
WATER. ORAL: SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:=-4.C, 24.8F
Autoignition Temp:=365.C, 689.F
Lower Limits:1.3%
Upper Limits:18.6%
Extinguishing Media:USE DRY CHEMICAL, CARBON DIOXIDE, ALCOHOL
FOAM/WATER FOG FOR SMALL FIRE. USE ALCOHOL FOAM, WATER SPRAY FOR
LARGE FIRE.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. COOL FIRE-EXPOSED CONTAINERS
WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:VAPOR IS HEAVIER THAN AIR AND CAN TRAVEL
CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK.
CONTAINERS MAY RUPTURE DUE TO VAPOR PRESSURE BUILDUP.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. PICK UP SPILL WITH NON-FLAMMABLE
ABSORBENT SUCH AS SAND OR VERMICULITE. TRANSFER TO DISPOSAL DRUMS
USING NON-SPARKING TOOLS. P REVENT LIQUID FROM ENTERING SEWERS OR
WATERWAYS.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, VENTILATED AREA, AWAY
FROM HEAT, FLAMES, SPARKS, HOT SURFACES AND STRONG OXIDIZING
AGENTS. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:AVOID BREATHING VAPORS. DO NOT GET IN EYES, ON SKIN
OR ON CLOTHING. WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING OR
DRINKING. KEEP OUT OF REACH OF CHILDREN. DO NOT INGEST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCENTRATION IS HIGH, WEAR A
NIOSH-APPROVED ORGANIC VAPOR RESPIRATOR.
Ventilation:USE EXPLOSION-PROOF VENTILATION EQUIPMENT TO CONTROL VAPOR
CONCENTRATIONS.
Other Protective Equipment:SAFETY SHOWER AND EYE WASH FOUNTAIN SHOULD
BE LOCATED NEARBY. WEAR APPROPRIATE PROTECTIVE CLOTHING FOR RISK OF
EXPOSURE.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
NRC/State Lic Num:NOT RELEVANT
Vapor Pres:44.6 @ 77F
Vapor Density:>1
Spec Gravity:0.77
Viscosity:0.64 CST
Appearance and Odor:COLORLESS LIQUID; ETHER-LIKE ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, FLAMES, SPARKS, HOT SURFACES, OTHER
IGNITION SOURCES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
SILICONE DIOXIDE AND FORMALDEHYDE MAY BE FORMED DURING COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN AN APPROVED INCINERATOR OR
CONTRACT WITH LICENSED CHEMICAL WASTE DISPOSAL SERVICE. DISCHARGE,
TREATMENT OR DISPOSAL IS SUBJECT TO FEDERAL, STATE OR LOCAL LAWS.
EPA D001 (IGNITABLE). FOR MORE INFORMATION, CALL DOW AT
517-496-6315.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:FEL-PRO C-102, 51605
Preparer's Name:DIANE L. GALLAGHER
CAGE:FO660
CAGE:FO660
CAGE:73165
============= Composition/Information on Ingredients =============
Ingred Name:CALCIUM FLUORIDE
CAS:7789-75-5
RTECS #:EW1760000
Ingred Name:GRAPHITE; (GRAPHITE FLAKES)
CAS:7440-44-0
RTECS #:FF5250100
OSHA PEL:10MG/M3 TDUST; 5RESP
ACGIH TLV:2 MG/M3 RESP
Ingred Name:MINERAL OIL (REFINED MINERAL OIL BASE) (INGS # 1 & 2
SUSPENDED IN THIS INGREDIENT)
CAS:8012-95-1
RTECS #:PY8030000
OSHA PEL:5 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NO ACUTE OR CHRONIC HEALTH HAZARDS
KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD . EYES:
FLUSH W/TEPID WATER FOR AT LEAST 15 MIN, HOLDING EYELIDS APART. D O
NOT RUB EYES. SEEK MED ATTN. INGESTION:LARGE AMOUNTS MAY RESULT IN
DIARRHEA. GET MED ATTN; TREAT SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:440F,227C
Extinguishing Media:USE WATER FOG, DRY CHEMICALS, FOAM OR CO*2.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
USE EYE PROT. USE EXTINGUISHING MEDIA.
Unusual Fire/Explosion Hazard:PYROLYSIS MAY RESULT IN HYDROFLUORIC ACID
FUMES. SAME AS FOR GREASE FIRES.
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP UP, WIPE UP WITH RAGS OR USE ABSORBENT
MATERIAL. COMPLETE CLEANUP USING DETERGENT & WATER, OR HIGH FLASH
POINT SOLVENT OR CHLORINATED SOLVENT CLEANER WITH ADEQUATE
VENTILATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE NORMAL STORAGE & HANDLING. DO NOT
EXPOSE TO HIGH HEAT, OPEN FLAMES OR STRONG OXIDIZERS.
Other Precautions:CONTAINS HYDROCARBONS - DO NOT USE IN OXYGEN SERVICE.
KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NONE REQUIRED.
Ventilation:LOCAL, MECHANICAL EXHAUST ACCCEPTABLE.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NO SPECIAL WORK OR HYGIENIC PRACTICES REQUIRED.
Supplemental Safety and Health
BP: > 400F, 204C @ 760 MMHG.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:SUPDAT
Melt/Freeze Pt:M.P/F.P Text:NEGLIGIBLE
Vapor Pres:NEGLIGIBLE
Spec Gravity:1.14 (H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK PASTE, SLIGHT PETROLATUM ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, SUCH AS PEROXIDES, PERMANGANATES, NITRIC ACID, ETC.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:PYROLYSIS MAY YEILD CO, CO*2,
INCOMPLETELY BURNED HYDROCARBONS AND HF.
==================== Disposal Considerations ====================
Waste Disposal Methods:USE CONTROLLED INCINERATION OR BURY IN A POSTED
LANDFILL IN ACCORDANCE WITH FEDERAL, STATE & LOCAL REGULATIONS.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:DOD-E-24607 SOFT WHITE
Preparer's Name:HENRY SIMMONS
CAGE:028S6
CAGE:028S6
============= Composition/Information on Ingredients =============
Ingred Name:TRIMETHYLBENZENE
CAS:25551-13-7
RTECS #:DC3220000
Minumum % Wt:1.
Maxumum % Wt:10.
ACGIH TLV:123 MG/M3;25 PPM
Ingred Name:ALUMINUM HYDROXIDE
CAS:21645-51-2
RTECS #:BD0940000
Minumum % Wt:1.
Maxumum % Wt:10.
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Minumum % Wt:10.
Maxumum % Wt:25.
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:MINERAL SPIRIT
CAS:8052-41-3
RTECS #:WJ8925000
Minumum % Wt:10.
Maxumum % Wt:25.
OSHA PEL:2900 MG/M3;500 PPM
ACGIH TLV:525 MG/M3;100 PPM
Ingred Name:1,2,4-TRIMETHYLBENZENE
CAS:95-63-6
RTECS #:DC3325000
Minumum % Wt:1.
Maxumum % Wt:10.
Ingred Name:AMORPHOUS SILICA
CAS:7631-86-9
Minumum % Wt:1.
Maxumum % Wt:10.
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Effects of Overexposure:INHALATION: MILDLY TOXIC BY INHALATION.
CAUSES NOSE AND THROAT IRRITATION.HARMFUL IF INHALED, MAY EFFECT
THE BRAIN OR NERVOUS SYSTEM CAUSING DIZZINESS, HEADACHE OR NAUSEA.
EYE CONTACT: CAUSES EYE IRRITATION. SKIN CONTACT: CAUSES SKIN
IRRITATIONINGESTION: HARMFUL IF SWALLOWED
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF DISCOMFORT IS PRESENT OR
BREATHING IS ABSENT GET MEDICAL ATTENTION IMMEDIATELY. EYE
CONTACT: FLUSH IMMEDIATELY WITH PLENTY OF WATER FOR 15 MINUTES
UNTIL IRRITATION SUBSIDES. IF IRRITATION PERSISTS, GET MEDICAL
ATTENTION.SKIN CONTACT: FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF
WATER. USE SOAP IF AVAILABLE. REMOVE SEVERELY CONTAMINATED CLOTHING
(INCLUDING SHOES) A S WASH BEFORE REUSE. IF IRRITATION PERSISTS,
GET MEDICAL ATTENTION. INGESTION: IF SWALLOWED, DO NOT INDUCE
VOMITING. KEEP AT REST. GET PROMPT MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:=40.6C, 105.F
Lower Limits:1
Extinguishing Media:FOAM. CARBON DIOXIDE, DRY CHEMICAL.
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT, SPARKS, ELECTRICAL
EQUIPMENT AND OPEN FLAME. CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. IN THE ABSENCE OF ELECTRICITY, A WATER
SPRAY (A FOG NOZZLES IS PREFERRED) MA Y BE USED TO COOL CONTAINERS.
DECOMPOSITION AND COMBUSTION PRODUCTS MAY BE TOXIC.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILLED LIQUID WITH SAND OR EARTH. DO
NOT USE COMBUSTIBLE MATERIALS SUCH AS SAWDUST. ABSORB SPILL WITH AN
INERT MATERIAL (E.G., DRY SAND OR EARTH), THEN PLACE IN A CHEMICAL
CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. LOOSEN CLOSURE
CAUTIOUSLY BEFORE OPENING. STORE IN A COOL, WELL VENTILATED PLACE
AWAY FROM INCOMPATIBLE MATERIALS. KEEP AWAY FROM HEAT, SPARKS AND
FLAMES. PROTECT MATERIAL FROM DIRECT SUNLIGHT. GROUND AND BOND
CONTAINERS WHEN TRANSFERRING MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DO NOT BREATHE VAPORS OR SPRAY MIST. IF YOU
EXPERIENCE EYE WATERING, HEADACHE OR DIZZINESS OR IF AIR MONITORING
DEMONSTRATES VAPOR/MISTS LEVELS ARE ABOVE APPLICABLE LIMITS, WEAR
AN APPROPRIATE, PROPER LY FITTED RESPIRATOR (NIOSH APPROVED) DURING
AND AFTER APPLICATION. FOLLOW RESPIRATOR MANUFACTURE?S DIRECTION;
FOR RESPIRATOR USE.
Ventilation:PROVIDE SUFFICIENT VENTILATION, IN VOLUME AND PATTERN, TO
KEEP THE TLV OF THE HAZARDOUS INGREDIENTS BELOW THE LIMITS
SPECIFIED AND REMOVE VOLATILES.
SHOULD BE WORN.
Other Protective Equipment:CLOTHING: AS NEEDED, USE BODY PROTECTION TO
AVOID CONTACT WITH PRODUCT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:=76.1C, 169.F
Vapor Density:> AIR
Spec Gravity:1.781
Evaporation Rate & Reference:SLOWER/ETHER
Appearance and Odor:LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO DECOMPOSITION AS IN WELDING. FUMES MAY PRODUCE CARBON
DIOXIDE AND CARBON MONOXIDE.
=================== Toxicological Information===================
Toxicological Information:THERE IS NO DATA ON THE PRODUCT ITSELF.
CONTAINS 1,2,4 - TRIMETHYL BENZENE WHICH CAUSE CENTRAL NERVOUS
SYSTEM DEPRESSION, ANEMIA AND BRONCHITIS. NOTICE: REPOTS HAVE
ASSOCIATED REPEATED AND PROLONGED OCCUPATIONAL OVEREXPOSURE TO
SOLVENTS WITH PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE.
INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND INHALING THE
HARMFUL OR FATAL.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS. DO NOT INCINERATE UNOPENED CONTAINERS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:COLL0DION FLEXIBLE 9247;CODE:N910023
CAGE:JO953
CAGE:JO953
CAGE:97807
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ETHER (SARA III)
CAS:60-29-7
RTECS #:KI5775000
Fraction by Wt: 65%.O
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400PPM/500STEL; 9192
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:ETHYL ALCOHOL (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 20.0%
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9192
Ingred Name:NITROCELLULOSE
Fraction by Wt: 4.8%
Ingred Name:CAMPHOR, SYNTHETIC
CAS:76-22-2
RTECS #:EX1225000
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3/3 STEL; 9192
Ingred Name:CASTOR OIL
CAS:8001-79-4
RTECS #:FI4100000
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATION OF
EYES,SKIN,RESPIRATORY OR G.I.TRACTS;CNS EFFECTS LIKE
HEADACHE,DIZZINESS,POOR APPETITE,WEIGHT LOSS,NAUSEA AND
VOMITING.CHRONIC:RESPIRATORY FAILURE,CNS,BLOOD OR KIDNEY DAMAGE.
Explanation of Carcinogenicity:DATA PER MSDS
Effects of Overexposure:SEE HEALTH HAZARDS DATA.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
FOR 15 MINUTES HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION.
SKIN:REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER. IF
IRRITATION PERSISTS, GET MEDICAL ADVICE. INGESTION:DO NOT INDUCE
VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET IMMEDIATE
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-49F,-45C
Lower Limits:3.3
Upper Limits:36.0
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:SUNLIGHT,FIRE OR EXCESSIVE HEAT MAY CAUSE
EXPLOSION DUE TO PRESSURE BUILD UP.STORE IN COOL PLACE.AVOID
ELECTRIC SPARKS.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION(SCBA);REMOVE
ALL IGNITION SOURCES;USE NON SPARKING TOOLS;CONTAIN FREE MATERIAL
IF POSSIBLE;USE SUITABLE INERT ABSORBENT MATERIAL AND RECOVER FOR
PROPER DISPOSAL IN AN AP PROVED CONTAINER.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED.PROTECT CONTAINERS FROM
PHYSICAL DAMAGE.KEEP AWAY FROM HEAT,OPEN FLAMES,SPA
Other Precautions:AVOID CONTACT WITH EYES,SKIN AND CLOTHES.DO NOT USE
CONTAMINATED CLOTHES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC
VAPORS/MIST AS REQUIRED IF ABOVE PEL/TLV OR SCBA IN AN ENCLOSED
AREA.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV.(EXPLOSION PROOR
EPUIPMENT.)
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER,WORK
CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS.
================== Physical/Chemical Properties ==================
HCC:F1
Boiling Pt:B.P. Text:94.0F,34.4C
Vapor Density:>1.0
Spec Gravity:0.776
pH:NEUTRL
Evaporation Rate & Reference:<1.0(ETHER=1)
Solubility in Water:PARTIALLY SOLUBLE
Appearance and Odor:COLORLESS OR SLIGHTLY YELLOW SOLUTION WITH ETHER
AND CAMPHOR ODOR
Percent Volatiles by Volume:90.13
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS,STRONG BASES,ACIDS,CERTAIN AMINES.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN
FLAMES,LIGHT.DO NOT ALLOW TO EVAPORATE TO DRYNESS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES.DISPOSAL MUST BE MADE
IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:NICKEL CADIUM BATTERY
Resp. Party Other MSDS Num.:P/N BB-590/T
CAGE:51828
Contract Num:SP0430-00-M-G417
CAGE:51828
============= Composition/Information on Ingredients =============
Ingred Name:NICKEL AND NICKEL HYDROXIDE (20-30% AS NI)
Minumum % Wt:13.
Maxumum % Wt:29.
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:CADMIUM AND CADMIUM HYDROXIDE (13-15% AS CADMIUM)
Minumum % Wt:11.
Maxumum % Wt:26.
OSHA PEL:0.2 MG/M3
ACGIH TLV:0.2 MG/M3
Ingred Name:COBALT AND COBALT HYDROXIDE
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.1 MG/M3
Ingred Name:POTASSIUM HYDROXIDE (2-4% AS DRY KOH)
< Wt:3.
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THESE CHEMICALS ARE CONTAINED IN A
SEALED CAN. RISK OF EXPOSURE OCCURS ONLY IF THE BATTERY IS
MECHANICALY OR ELECTRONICALLY ABUSED. MOST LIKELY, RISK IS WHEN A
CELL LEAKS. KOH IS CAUSTIC & SKIN CONTAC T CAN CAUSE IRRITATION OR
BURNS. EYE CONTACT WITH KOH MAY CAUSE PERMANENT INJURY.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:IF LEAKAGE FROM CELL CONTACTS: SKIN: FLUSH WITH WATER. WASH
WITH SOAP & WATER. IF IRRITATION PERSISTS CONTACT PHYSICIAN. EYES:
IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF WATER FOR 15 MINS. THEN
SEE PHY SICIAN AT ONCE.
===================== Fire Fighting Measures =====================
Upper Limits:NONE PROVIDE
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE SELF CONTAINED
BREATHING APPARATUS WHEN A LARGE NUMBER OF CELLS ARE INVOLVED.
Unusual Fire/Explosion Hazard:MAY BURST WHEN SUBJECT TO EXTREME HEAT.
CADMIUM FUMES BAY BE RELEASED DURING BURNING.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID SKIN & EYE CONTACT. COLLECT ALL RELEASED
MATERIAL IN A PLASTIC BAG FOR WASTE DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT SHORT CIRCUIT. STORE IN COOL,
DRY PLACE. USE PROPER BATTERY CHARGER.
Other Precautions:AVOID INCINERATION OR MUTILATION. USE BATTERY IN
PROPER EQUIPMENT. OBSERVE CORRECT POLARITY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS IN ANY FIRE SITUATION, USE SELF CONTAINED
BREATHING APPARATUS. (SCBA)
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:Z5
Percent Volatiles by Volume:NONE PROVIDE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:DO NOT HEAT OR DISASSEMBLE. DO NOT SHORT
CIRCUIT.
Hazardous Decomposition Products:DO NOT INCINERATE OR MUTILATE; MAY
BURST OR RELEASE TOXIC MATERIALS.
Conditions to Avoid Polymerization:WILL NOT OCCUR
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE. DISPOSE OF IN ACCORDANCE WITH
LOCAL REGULATIONS. SM QUANTITIES ARE USUALLY ALLOWED IN HOUSEHOLD
TRASH.
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:P150F1212
CAGE:JO868
CAGE:JO868
CAGE:00656
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR.AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UNC ONSCIOUS PERSON VOMIT.
===================== Fire Fighting Measures =====================
Flash Point:< 3 LB PCB
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:DELTA-LITE FIBREGLASS CASTING TAPE
CAGE:79717
CAGE:79717
============= Composition/Information on Ingredients =============
Ingred Name:POLYPROPYLENE POLYOL DIPHENYL METHANE DIISOCYANATE
PREPOLYMER
CAS:9048-57-1
Fraction by Wt: 31-34%
Other REC Limits:NONE SPECIFIED
Ingred Name:METHYLENE BISPHENYL ISOCYANATE (MDI) (SARA III)
CAS:101-68-8
RTECS #:NQ9350000
Fraction by Wt: 5-8%
Other REC Limits:NONE SPECIFIED
OSHA PEL:C, 0.02 PPM
ACGIH TLV:0.005 PPM; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ALUMINUM (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15MG/M3 DUST/5 FUME
ACGIH TLV:10MG/M3 DUST; 9192
Ingred Name:FIBERGLASS
Fraction by Wt: 54%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3(TOTAL DUST)
ACGIH TLV:10 MG/M3 (DUST)
Ingred Name:POLYETHYLENE AS A COPOLYMER
Fraction by Wt: 2%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS UNKNOWN.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: CURING OF PREPOLYMER AND CAST
REMOV MAY CAUSE EYE AND SKIN IRRITATION. HEATING BEFORE CURING MAY
RELEASE ISOCYANAT VAPORS WHICH MAY CAUSE RESPIRATORY TRACT
IRRITATION. INGESTION MAY CAUSE IRRITA TION WITH POSSIBLE CORROSIVE
ACTION. EXCESSIVE EXPOSURE TO VAPORS MAY CAUSE PULMONARY EDEMA AND
MAY BE DELAYED.
Effects of Overexposure:REDNESS, SMARTING, TEARING & SWELLING OF THE
EYE. DRYNESS & CRACKING OF THE SKIN. VOMITING FROM INGESTION.
INGESTION OF THE CAST MATERIAL MAY CAUSE PHYSICAL BLOCKAGE OF THE
GI TRACT.
Medical Cond Aggravated by Exposure:PEOPLE WITH CHRONIC DISEASES OF THE
SKIN MAY BE AT INCREASED RISK WHEN EXPOSED TO THIS MATERIAL.
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE PERSON TO FRESH AIR.RESTORE BREATHING. TREAT
SYMPTOMATICALLY. GET MEDICAL HELP. EYES: FLUSH IMMEDIATELY WITH
LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. GET MEDICAL
TREATMENT. SKI N: WASH AFFECTED SKIN AREAS WITH SOAP AND WATER.
REMOVE CONTAMINATED CLOTHING. CONSULT A PHYSICIAN FOR ALLERGIC SKIN
REACTION.INGESTION: DO NOT INDUCE VOMITING: GET IMMEDIATE MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>350F,>177C
Autoignition Temp:Autoignition Temp Text:NONE
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCB &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE.
Unusual Fire/Explosion Hazard:FIRES CAN RELEASE NITROGEN OXIDES AND
ISOCYANATE VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:EXPOSED PREPOLYMER WILL REACT WITH AMBIENT
MOISTURE AND POLYMERIZE (HARDEN). A DILUTE AMMONIA SOLUTION (10%)
WILL NEUTRALIZE UNREACTED PREPOLYMER.
Neutralizing Agent:10% AMMONIA SOLUTION
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE TEMPERATURES SHOULD NOT EXCEED
75F TO PREVENT PREMATURE POLYMERIZATION OF THE PRODUCT.
Other Precautions:AVOID CONTACT WITH SKIN AND EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED DURING CAST APPLICATION. DURING
CAST REMOVAL USE NIOSH/MSHA APPROVED RESPIRATORS FOR DUST IF
CONCENTRATION EXCEEDS THE TLV FOR NUISANCE DUST.
Ventilation:NORMAL MECHANICAL VENTILATION DURING CAST APPLICATION.
RECOMMEND LOCAL EXHAUST DURING CAST REMOVAL.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR SMOKING OR USING
THE WAS ROOM. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
THE FIBERGLASS SUBSTRATE IS A LOW DUST/FIBER RELEASING MATERIAL. FREE
FIBERGLASS DUST PARTICLES ARE NOT EXPECTED TO BE RELEASED AS THE
SUBSTRATE IS BOUND BY THE PREPOLYMER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:392F,200C
Vapor Pres:NIL
Spec Gravity:1.23-PREPOLYMER
Solubility in Water:REACTS
Appearance and Odor:4 YDX3 IN BANDAGE (FIBERGLASS SUBSTRATE COATED WITH
A POLYURETHANE RESIN.
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
WATER, STRONG ALKALI, ALCOHOLS, METAL COMPOUNDS, SURFACE ACTIVE AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:CARBON DIOXIDE & CARBON DIOXIDE,
NITROGEN OXIDES AND ISOCYANATE VAPORS.
Conditions to Avoid Polymerization:POLYMERIZATION MAY OCCUR IF MATERIAL
IS HEATED FOR LONG PERIODS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE DONE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS.HARDENED CAST MATERIAL IS NOT
CLASSIFIED AS A HAZARDOUS WASTE AND MAY BE DISPOSED OF IN AN
ORDINARY LANDFILL.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:5020/7020 DEVELOPER - SAVIN
Preparer's Name:KRISTINA SAGE
CAGE:S0407
CAGE:7E267
CAGE:S0407
CAGE:29382
============= Composition/Information on Ingredients =============
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: <3%
Other REC Limits:NONE SPECIFIED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9091
Ingred Name:STYRENE ACRYLIC RESIN
Fraction by Wt: <3%
Other REC Limits:NONE SPECIFIED
Ingred Name:DYE (PROPRIETARY)
Fraction by Wt: <3%
Other REC Limits:NONE SPECIFIED
Ingred Name:FERRITE
Fraction by Wt: <97%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS > 10G/KG BODYWEIGHT.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MAY CAUSE TEMPORARY DISCOMFORT.
SKIN: MAY CAUSE SLIGHT IRRITATION ON PROLONGED CONTACT.
INHALATION: GASPING. INGESTION: PRACTICALLY NON-TOXIC.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:GASPING WITH INHALATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH RUNNING WATER FOR 15 MINUTES WHILE HOLDING
EYELID. GET MEDICAL ATTENTION. SKIN: WASH WITH SOAP & WATER. REMOVE
CONTAMINATED CLOTHING. INHALATION: REMOVE FROM EXPOSURE.
INGESTION: DIL UTE STOMACH CONTENTS WITH SEVERAL GLASSES OF WATER.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:NO SPECIAL FIRE-FIGHTING PROCEDURE IS
NECESSARY.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:IF SPILLED, SWEEP UP OR PICK UP BY VACUUM
CLEANER. REMOVE RESIDUE WITH SOAP AND COLD WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL AND DRY PLACE. KEEP OUT
OF REACH OF CHILDREN.
Other Precautions:DO NOT HANDLE IN AREAS WHERE WIND BLOWS. FLYING
POWDER MAY ENTER EYES. MINIMIZE INHALATION OF DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:MECHANICAL (GENERAL) VENTILATION IS ADEQUATE. LOCAL EXHAUST
NOT NORMALLY NEEDED.
Other Protective Equipment:NONE NORMALLY REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES.
LAUNDER CONTAMINATED CLOTHING BEFORE REUSE. KEEP WORK AREA CLEAN.
Supplemental Safety and Health
MINIMIZE BREATHING DUST.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:>176F,>80C
Spec Gravity:1.97
Solubility in Water:NEGLIGIBLE; <0.1%
Appearance and Odor:BLACK POWDER, WITH SLIGHT PLASTIC ODOR.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Hazardous Decomposition Products:CARBON MONOXIDE AND OTHER
DECOMPOSITION PRODUCT IN CASE OF INCOMPLETE COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:USED DEVELOPER SHOULD BE DISPOSED OF IN AN
ENVIRONMENTALLY SAFE MANNER AND IN ACCORDANCE WITH GOVERNMENTAL
REGULATIONS. DO NOT INCINERATE.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:CC-13 HIGH PRESSURE WASH COMPOUND
Preparer's Name:MARK PLEMONS
CAGE:6U327
CAGE:6U327
============= Composition/Information on Ingredients =============
Ingred Name:NON HAZARDOUS INGREDIENT
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:EYE, RESPIRATORY OR DIGESTIVE IRRITATION WITH
ACUTE EXPOSURE.
Medical Cond Aggravated by Exposure:RESPIRATORY ILLNESS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MIN AND CALL
PHYSICIAN. INHAL: GET TO FRESH AIR AND CALL PHYSICIAN IF IRRITATION
PERSISTS. INGEST: DRINK 2 GLASSES OF WATER AND INDUCE VOMITING BY
TICKLING BACK OF THROAT WITH FINGER. SKIN: FLUSH WITHCOPIOUS
AMOUNTS OF WATER. CALL PHYSICIAN .
===================== Fire Fighting Measures =====================
Extinguishing Media:SUITABLE FOR COMBUSTIBLES IN AREA.
Fire Fighting Procedures:NOT APPLICABLE. WEAR NIOSH/MSHA APPROVED SCBA
AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT APPLICABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:DILUTE AND FLUSH TO SEWER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM STRONG ACIDS AND
OXIDIZERS.
Other Precautions:USE ONLY AS DIRECTED ON LABEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR FOR DUSTS, FUMES
OR MISTS.
Ventilation:LOCAL EXHAUST: USUALLY SUFFICIENT.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:218F,103C
Spec Gravity:1.08
Solubility in Water:COMPLETE
Appearance and Odor:YELLOW-GREEN LIQUID WITH BLAND CHEMICAL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT.
Hazardous Decomposition Products:OXIDES OF CARBON AND OF PHOSPHOROUS
WHEN BURNING.
==================== Disposal Considerations ====================
Waste Disposal Methods:NOT APPLICABLE. DISPOSAL MUST BE IN ACCORDANCE
WITH FEDERAL, STATE AND LOCAL REGULATIONS .
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:ORTHOPHOSPHORIC ACID,TECHNICAL
CAGE:1F176
CAGE:1F176
CAGE:97854
CAGE:23894
============= Composition/Information on Ingredients =============
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 ORAL RAT IS 1530 MG/KG (PHOSP. AC.)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CORROSIVE. CAN CAUSE BURNS OR
DESTRUCTION OF EXPOSED TISSUE. EXTENSIVE BURNS MAY BE FATAL.
INHALATION MAY CAUSE PULMONARY EDEMA. CHRONIC: PERMANENT EYE
DAMAGE, BLINDNESS. PROLONGED SKIN CONTACT MAY CAUSE DERMATITIS OR
SKIN TISSUE DESTRUCTION.
Effects of Overexposure:SEVERE IRRITATION AND BURNS TO ALL TISSUES
CONTACTED. EYES/SKIN: BURNING SENSATION. INHALATION: RESPIRATORY
TRACT IRRITATION, BREATHING DIFFICULTY. INGESTION: BURNING
SENSATION OF GASTROINTESTINAL SYS TEM, PAIN, NAUSEA, VOMITING,
BLOODY DIARRHEA, CONVULSION. IN SEVERE CASES, COLLAPSE AND DEATH.
Medical Cond Aggravated by Exposure:SKIN IRRITATION MAY BE AGGRAVATED
IN PERSONS WITH EXISTING SKIN LESIONS. BREATHING OF MISTS MAY
AGGRAVATE ACUTE OR CHRONIC ASTHMA OR OTHER RESPIRATORY DISEASES.
======================= First Aid Measures =======================
First Aid:EYE: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES. SEE DOCTOR. SKIN: FLUSH WITH PLENTY OF SOAP AND WATER
WHILE REMOVING CONTAMINATED CLOTHING UNDER THE SHOWER. CONTINUE
WASHING WITH WATER. SEE DOCTOR. INHALATION: REMOVE TO FRESH AIR.
GIVE OXYGEN/CPR IF NEEDED. SEE DOCTOR. INGESTION: DO NOT INDUCE
VOMITING. DILUTE ACID WITH LARGE QUANTITIES OF WATER OR MILK. SEE
DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, WATER SPRAY OR
REGULAR FOAM.
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING. COOL FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:PHOSPHORIC ACID CAN REACT WITH METALS TO
PRODUCE FLAMMABLE AND EXPLOSIVE HYDROGEN GAS. PHOSPHORIC ACID FUMES
ARE CORROSIVE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE PERSONNEL. VENTILATE. WEAR RESPIRATOR
AND PROTECTIVE CLOTHING. SLOWLY NEUTRALIZE WITH CHEMICAL AGENTS.
ABSORB IN INERT MATERIAL AND PLACE IN APPROPIATE DISPOSAL
CONTAINER. FLUSH AREA WITH LARGE AMOUNTS OF WATER.
Neutralizing Agent:SODA ASH, SODIUM BICARBONATE, OR LIME.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY AREA, AWAY FROM
YELLOW OR RED LABEL ITEMS. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT
IN USE. CORROSIVE TO MILD STEEL AND ALUMINUM.
Other Precautions:WHEN HANDLING THIS PRODUCT WEAR PROTECTIVE CLOTHING
AND EQUIPMENT. WHEN DILUTING, ALWAYS ADD ACID SLOWLY TO WATER. STIR
WELL TO AVOID SPATTERING. NEVER ADD WATER TO ACID.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA-APPROVED RESPIRATOR FOR ACID
MISTS WHEN HANDLING SPILLS OR LEAKS, OR WHEN AIRBORNE
CONCENTRATIONS EXCEED EXPOSURE LIMITS.
Ventilation:PROVIDE SUFFICIENT LOCAL EXHAUST VENTILATION TO KEEP
EXPOSURE LEVELS BELOW OSHA'S PEL.
Other Protective Equipment:INDUSTRIAL-TYPE WORK CLOTHING AND APRON,
HARD HAT, RUBBER BOOTS, SAFETY SHOWER, EYE WASH FOUNTAIN.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
DO NOT GET ON SKIN, IN EYES OR ON CLOTHING. DO NOT BREATHE VAPORS OR
MISTS. WASH HANDS AND FACE AFTER USE. KEEP CONTAINERS CLOSED WHEN
NOT IN USE. NOTE: THIS IS A PRE-HCS MSDS. CONSIDERABLE EDITING W
AS DONE BY DGSC-SSH.
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:275F,135C
Vapor Pres:15
Spec Gravity:1.58
pH:<1
Solubility in Water:COMPLETE
Appearance and Odor:WATER WHITE LIQUID, NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
FERROUS METALS AND ALLOYS, ALKALIES REACT WITH PHOSPHORIC ACID TO
PRODUCE FLAMMABLE AND EXPLOSIVE HYDROGEN GAS.
Stability Condition to Avoid:NONE NOTED.
Hazardous Decomposition Products:NONE NOTED.
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY WITH LOCAL, STATE, AND FEDERAL
REGULATIONS. LANDFILL IS SUITABLE AFTER PROPER NEUTRALIZATION. RCRA
HAZARDOUS WASTE NUMBER D002.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:24024C-91, FUJI AUDEL INDUSTRIAL DEVELOPER (SUPDAT)
Kit Part:Y
CAGE:1CG79
CAGE:1CG79
============= Composition/Information on Ingredients =============
Ingred Name:GLUTARALDEHYDE
CAS:111-30-8
RTECS #:MA2450000
Fraction by Wt: 35-40%
OSHA PEL:0.2 PPM, C
ACGIH TLV:0.2 PPM, C
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 60-65%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION:VAPOR MAY CAUSE IRRITATION
TO NOSE & THROAT. MAY CAUSE DIFFICULTY IN BREATHING. EYES:VAPOR MAY
CAUSE IRRITATION. CONTACT CAUSES IRRITATION. SKIN:REPEATED &
PROLONGED CONTACT MAY CAUSE IRRIT ATION. INGESTION:DO NOT TAKE
INTERNALLY. CAN CAUSE IRRITATION TO UPPER RESPIRATORY TRACT.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES.
SEEK MEDICAL ATTENTION IMMEDIATELY. SKIN:REMOVE CONTAMINATED
CLOTHING & FLUSH W/WATER. INGEST:DO NOT INDUCE VOMITING. DRINK
WATER OR MILK. SEEK MEDICAL ATTENTION IMMEDIATELY GIVING FULL
DETAILS OF AMOUNT INGESTED & TOXICITY. INHAL:MOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE METHOD APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:WHEN HEATED TO DECOMPOSITION, IT CAN EMIT
ACRID SMOKE & FUMES. WILL PRODUCE CO*2 & POSSIBLY CO.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE CLOTHING AS SPECIFIED IN
SPECIAL PROTECTION INFORMATION SECTION. NEUTRALIZE W/SODIUM
BICARBONATE. IF FEDERAL, STATE & LOCAL LAWS PERMIT, FLUSH TO SEWER
W/LARGE AMOUNTS OF WATER.
Neutralizing Agent:SODIUM BICARBONATE.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE OR CONSUME FOOD, DRINK OR
TOBACCO IN SURROUNDING AREA. KEEP AWAY FROM HEAT OR FLAME.
Other Precautions:KEEP AWAY FROM ALKALIS, AMINES, ALCOHOLS & STRONG
OXIDIZERS. CORROSIVE MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SHOULD NOT BE NECESSARY UNDER NORMAL CONDITIONS.
IF EXPOSED TO VAPORS THAT EXCEED TLV OR PEL, WEAR A NIOSH/MSHA
APPROVED VAPOR RESPIRATOR.
Ventilation:GOOD LOCAL MECHANICAL VENTILATION SHOULD BE SUFFICIENT.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . AS NECESSARY TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER USE.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:REPLENISHER PT C. WASTE DISP METH:ASCERTAIN
PROPER DISPOSAL PROCEDURES. EYE PROT:& FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:17
Vapor Density:0.6
Spec Gravity:1.08
pH:6.8
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR; ALDEHYDE ODOR.
Percent Volatiles by Volume:65(WT)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
KEEP AWAY FROM ALKALIS, AMINES, ALCOHOLS & STRONG OXIDIZERS.
Stability Condition to Avoid:KEEP AWAY FROM HEAT OR FLAME.
Hazardous Decomposition Products:WHEN HEATED TO DECOMPOSITION, IT CAN
EMIT TOXIC FUMES. WILL PRODUCE CO*2 & POSSIBLY CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:NEUT W/SODIUM BICARBONATE. IF FED, STATE &/OR
LOC LAWS PERMIT, FLUSH W/LG AMTS OF WATER. OTHERWISE DISP OF CONTAM
PROD & MATLS USED IN CLEANING UP SPILL IN MANNER APPRVD FOR THIS
MATL. CONSULT PROPER FED, STATE &/OR LOC REGULATORY
AGENCIESTO(SUPDAT)
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:PHOTOGRAPHIC FIXER/REPLENISHER PART B, 1002
Kit Part:Y
Preparer's Name:ENGINEERING DEPT
CAGE:47220
CAGE:47220
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM SULFATE (2:3)
CAS:10043-01-3
RTECS #:BD1700000
Fraction by Wt: 40-70%
OSHA PEL:2 MG/M3 (MFR)
ACGIH TLV:2 MG/M3 (MFR)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 25-50%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:MAY IRRITATE RESPIRATORY TRACT
AND EYE. SEVERE IRRITANT TO EYES. CHRONIC:NONE KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES AND GET MD. SKIN:FLUSH WITH PLENTY OF WATER, IF AN ALLERGIC
REACTION DEVELOPS, GET MD. INHAL:MOVE FROM EXPOSURE. INGEST:CALL MD
IMMED IATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:NONE
Lower Limits:NONE.
Upper Limits:NONE.
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, ALCOHOL FOAM, CARBON
DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILLS:FLUSH TO SEWER WITH LARGE AMOUNT
OF WATER. LARGE SPILLS:ABSORB MATERIAL IN VERMICULITE OR OTHER
SUITABLE ABSORBENT AND PLACE IN IMPERVIOUS CONTAINER.
Neutralizing Agent:SODIUM BICARBONATE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BETWEEN 10-25C (50-80F).
Other Precautions:AVOID CONTACT WITH EYES AND SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE REQUIRED. NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT.
Other Protective Equipment:CLOTHING THAT COVERS SKIN.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
KEY1: C3. THIS ENTRY DESCRIBES PART B OF A TWO PART KIT. SEE THIS SAME
NSN, P/N IND A, FOR PART A DATA. PH:3.5 @ 1% SOLUTION. WASTE DISP
METH:NORMAL MANNER. DISPOSAL MUST BE IN ACCORDANCE WITH ALL LOC AL,
STATE AND FEDERAL REGULATIONS .
================== Physical/Chemical Properties ==================
HCC:C3
Boiling Pt:B.P. Text:>212F,>100C
Spec Gravity:1.3
pH:SUPDAT
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID
Percent Volatiles by Volume:50
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BASES (CAUSTICS).
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:ABOVE 760 DEG C (1400F), SULFUR
DIOXIDE GASES WHICH ARE OXIDIZERS AND ARE CORROSIVE.
==================== Disposal Considerations ====================
Waste Disposal Methods:NO SPECIFIC METHOD NEC IF NEUTRALIZED.
DISCHARGE, TREATMENT, OR DISP MAY BE SUBJECT TO CERTAIN GOVERNMENT
REGS. EMPTY CNTNRS (THOSE CNTNG LESS THAN 3% BY WT OF TOTAL
CAPACITY OF CNTNR) ARE NOT REG UND ER HAZ WASTE REGS & MAY BE DISP
OF IN (SUPP DATA)
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:M06-MEGUIAR'S PROFESSIONAL CLEANER/WAX
CAGE:EO362
CAGE:EO362
CAGE:0M581
============= Composition/Information on Ingredients =============
Ingred Name:KEROSENE, KEROSINE
CAS:8008-20-6
RTECS #:OA5500000
Fraction by Wt: 18-25%
Other REC Limits:100 MG/CUM NIOSH
Ingred Name:DIMETHYL POLYSILOXANE (MONOMER: DIMETHYL SILOXANE),
SILICONE FLUID, DOW CORNING 200, POLYMETHYLSILOXANE
CAS:63148-62-9
RTECS #:JT6484500
Fraction by Wt: 4-12%
Ingred Name:SILICA CRYSTALLINE, TRIPOLI (SUSPECTED HUMAN CARCINOGEN BY
IARC.
CAS:1317-95-9
RTECS #:VV7336000
Fraction by Wt: 4-12%
Other REC Limits:30 MG/CUM TOTAL DUST
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:PETROLEUM HYDROCARBONS, SOLVENT DEWAXED RESIDUAL OIL
(PETROLEUM)
CAS:64742-62-7
Fraction by Wt: 0-6%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION. INGESTION: DIGESTIVE
SYSTEM IRRITATION. INHALATION: BREATHING TRACTS IRRITATION.
Explanation of Carcinogenicity:SILICA CRYSTALLINE IS A SUSPECTED HUMAN
CARCINOGEN.
Effects of Overexposure:SKIN: IRRITATION. INGESTION: DIGESTIVE SYSTEM
IRRITATION. INHALATION: BREATHING TRACT IRRITATION.
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/WATER. INGESTION:
DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:200F
Extinguishing Media:DRY CHEMICAL, WATER, FOAM, OR CO2
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN IN METAL, PLASTIC, OR GLASS CONTAINER
& ABSORB.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM ACIDS & OXIDIZERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED FOR NORMAL USE.
Ventilation:LOCAL EXHAUST: ADEQUATE.
Work Hygienic Practices:NORMAL
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:365F
Vapor Pres:NEG
Spec Gravity:1
Solubility in Water:COMPLETE
Appearance and Odor:THICK WHITE W/SWEET ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS & ACIDS
Hazardous Decomposition Products:CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE ABSORBENT MATERIALS IN SANITARY LANDFILL
OR AS REQUIRED BY FEDERAL, STATE, & LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:LINE PIPE & COUPLINGS HSLA STEEL, 4H020
CAGE:HO954
CAGE:61497
CAGE:HO954
============= Composition/Information on Ingredients =============
Ingred Name:IRON OXIDE
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 99%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
Ingred Name:GRAPHITE, SYNTHETIC
CAS:7440-44-0
RTECS #:FF5250100
Fraction by Wt: 0.29%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9293
Ingred Name:COLUMBIUM. PEL: 15 MG/M3 TDUST; 5 MG/M3 RDUST (MFR).
PERCENT: 0.01-0.08.
CAS:7440-03-1
Fraction by Wt: INGNAME
OSHA PEL:SEE INGREDIENT NAME
ACGIH TLV:10 MG/M3 TDUST (MFR)
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 1.6%
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
Fraction by Wt: INGNAME
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9293
Ingred Name:PHOSPHOROUS (YELLOW) (SARA III)
CAS:7723-14-0
RTECS #:TH3500000
Fraction by Wt: 0.025%
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.1 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SULFUR. PEL: 15 MG/M3 TDUST; 5 MG/M3 RDUST.
CAS:7704-34-9
RTECS #:WS4250000
Fraction by Wt: 0.025%
OSHA PEL:SEE INGREDIENT NAME
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:VANADIUM PENTOXIDE(SARA III)
CAS:1314-62-1
RTECS #:YW2460000
Fraction by Wt: INGNAME
OSHA PEL:C,0.5 MG/M3
ACGIH TLV:0.05 MG/M3RDUST;9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SUPP DATA: OF THIS PROD TO CAUSE TOXIC EFFECTS. STEEL PRODS
UNDER NORMAL CONDITIONS DO NOT PRESENT AN INHAL, (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: INGEST, CONT HLTH/ENVIRONMENTAL HAZ. HOWEVER, OPER
SUCH AS BURNING, WELDING, SAWING, BRAZING, GRINDING, (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: AND POSSIBLY MACHINING, ETC, WHICH RESULT IN
ELEVATING TEMP OF PROD TO/ABOVE ITS MELTING POINT/RESULT (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: IN GENERATION OF AIRBORNE PARTICULATES, MAY PRESENT
HEALTH HAZARDS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 4
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CHRONIC INHAL OF HIGH CONC OF IRON
OXIDE FUMES/DUSTS MAY LEAD TO A BENIGN PNEUMOCONIOSIS (SIDEROSIS).
INHAL OF HIGH CONC OF FERRIC OXIDE MAY POSS ENHANCE RISK OF LUNG
CANCER DEVELOPMENT IN WORKERS EXP SD TO PULM CARCINOGENS. THE INHAL
OF HIGH CONC OF FRESHLY FORMED OXIDE FUMES & DUSTS OF MANGANESE,
(SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: COPPER, LEAD AND/OR ZINC IN THE
RESPIRABLE PARTICLE SIZE RANGE CAN CAUSE AN INFLUENZA-LIKE ILLNESS
TERMED METAL FUME FEVER. TYPICAL SYMP LAST 12 TO 48 HRS & ARE
CHARACT BY METALLIC TASTE IN MOUTH, DRYNESS & IRRIT OF THROAT,
FOLLOWED BY WEAKNESS, MUSCLE PAIN, FEVER & CHILLS. CONTINUOUS EXPOS
TO HIGH(SUPP DATA)
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH CHRONIC
RESPIRATORY DISORDERS (I.E. ASTHMA, CHRONIC BRONCHITIS, EMPHYSEMA,
ETC) MAY BE ADVERSELY AFFECTED BY AN FUME OR AIRBORNE PARTICULATE
MATTER EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHAL:FOR OVEREXP TO AIRBORNE FUMES & PARTICULATES, REMOVE
EXPSD PERSON TO FRESH AIR.IF BRTHG DFCLT/STOPS, ADMIN ARTF
RESP/OXYGEN AS INDICATED.CALL MD IMMED.TREAT METAL FUME FEVER BY
BED REST & ADMIN PAIN & FEVER REDUCING MEDICATION.SKIN:IF THERMAL
BURN OCCURS, FLUSH AREA W/COLD WATER.CALL MD.FOR MECH
ABRASIONS,CALL MD. EYES:FLUSH W/ LRG AMTS OF WATER FOR AT LEAST 15
MIN TO REMOVE PARTICLES.CALL M
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT FLAM OR COMBUSTIBLE. STEEL PRODUCTS
IN THE SOLID STATE PRESENT NO FIRE OR EXPLOSION HAZARD AND DO NOT
CONTRIBUTE TO THE COMBUSTION OF OTHER MATERIALS.
================== Accidental Release Measures ==================
Spill Release Procedures:NOT APPLICABLE TO STEEL IN SOLID STATE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:OPER W/POTENTIAL FOR GENERATING HIGH
CONC OF AIRBORNE PARTICULATES SHOULD BE EVAL & CONTROLLED AS NEC.
AVOID BRTHG METAL FUMES AND/OR DUSTS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED DUST AND FUME RESPIRATORS
SHOULD BE USED TO AVOID EXCESSIVE INHALATION OF PARTICULATES.
APPROPRIATE RESPIRATOR SELECTION DEPENDS ON THE MAGNITUDE OF
EXPOSURE.
Ventilation:LOC EXHST VENT SHOULD BE PROVIDED WHEN WELDING/BURNING/
SAWING/BRAZING/GRINDING/MACHINING TO PVNT EXCESS DUST/FUME EXPOS
Other Protective Equipment:DEPEND UPON CNDTNS OF USE AND SPECIFIC WORK
SITUATIONS, ADDTNL PROTECTIVE EQUIPMENT AND/OR CLOTHING MAY BE
REQUIRED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP: CONC OF MANGANESE CAN CAUSE CNS DISORDERS & "MANGANESE
PNEUMONIA". FIBROSIS OF LUNG TISS FROM MANGANESE EXPOS HAS ALSO
BEEN RPTD FOR PRODS CONTAINING MANGANESE ONLY. LONG TERM INHAL E
XPOS TO HIGH CONC (OVEREXP) TO PNEUMOCONIOTIC AGENTS MAY ACT
SYNERGISTICALLY W/INHAL OF OXIDES, FUMES/DUSTS (SEE ING 9)
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:2750F,1510C
Spec Gravity:7.85
Solubility in Water:NOT SOLUBLE
Appearance and Odor:METALLIC GRAY SOLID WITH NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WILL REACT WITH STRONG ACID TO LIBERATE HYDROGEN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:AT TEMPERATURES ABOVE THE MELTING
POINT, MAY LIBERATE FUMES CONTAINING OXIDES OF IRON AND ALLOYING
ELEMENTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:102 2656,PROSTAR PLUS FIXER
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIUM THIOSULFATE(20-25%)
CAS:7783-18-8
RTECS #:XN6465000
Fraction by Wt: 22.5%
Ingred Name:WATER (75-80%)
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 77.5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NOT KNOWN
Effects of Overexposure:INH/EYES/SKIN:MFR STATES,LOW HAZARD FOR USUAL
INDUSTRIAL HANDLING.
Medical Cond Aggravated by Exposure:NOT KNOWN
======================= First Aid Measures =======================
First Aid:GOOD INDUSTRIAL HYGIENE SAFETY PROCUDURES SHOULD BE
FOLLOWED.HOWEVER,MFR STATES,IN CASE OF EYES/SKIN CONTACT,FLUSH WITH
PLENTY OF WATER.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NONE
Fire Fighting Procedures:WEAR SCBA & PROTECTIVE CLOTHING TO AVOID
SKIN/EYES CONTACT.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:MFR SUG FLUSH TO SEWER W/COPIOUS AMTS OF
WATER.STATE & LOCAL EFFLUENT LAWS TAKE PRECEDENCE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENT,LOW FIRE
RISK AREA. PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL CONTACT.
KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT(10 FM VOL/HR)
Other Protective Equipment:NORMAL WORK CLOTHING COVERING ARMS & LEGS.
Supplemental Safety and Health
PER MFR LETTER,AUG 15,83,PART NO OF ITEM CHANGED FROM 197 3098 PROST
FIXER TO AS SHOWN IN THE PART NO FIELD;THE OLD MSDS WAS DATED
5/19/80 AND HAD THE SAME COMPONENT PERCENTAGES AS WRITTEN ON THE
MSDS OF 1/13/84.ACTUALLY,THERE WAS NO FORMULA CHANGE;SOLUTION
#4266.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>212F/100C
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.13
pH:8.0
Evaporation Rate & Reference:0.36(BUTYL ACETATE
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS SOLUTION;ODORLESS
Percent Volatiles by Volume:94
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MINERAL ACIDS,METAL ALKALI
Hazardous Decomposition Products:AMMONIA
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH TO SEWER WITH COMPIOUS AMOUNTS OF
WATER.FEDERAL,STATE AND LOCAL DISPOSAL AND EFFLUENT LAWS TAKE
PRECEDENCE.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:PURE TUNGSTEN (WOLFRAM) WELDING ELECTRODES
CAGE:JO533
Contract Num:SP0490-00-M-BE24
CAGE:0A4S7
CAGE:JO533
============= Composition/Information on Ingredients =============
Ingred Name:TUNGSTEN
CAS:7440-33-7
RTECS #:YO7175000
> Wt:99.9
ACGIH TLV:5 MG/M3
ACGIH STEL:10 MG/M3
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NO SPECIFIC DATA, TESTING OF
INFORMATION HAS BEEN FOUND FOR THE CHEMICAL COMPOUND(S) THAT
COMPRISE THIS PRODUCT ACCORDING, GENERAL SOURCE COMMENTS ARE MADE
BELOW FOR THE ELEMENTS INCLUDED IN ITS COMPO SITION. INHALATION OF
TUNGSTEN DUSTS, FLAMES, OR MISTS CONTAINING TUNGSTEN.
Effects of Overexposure:NO INHALATION HAZARD IS POSSIBLE FOR SOLID,
FORMED PART, IT POWDER OF DUST MAY BE GENERATED, AS FORM MACHING OF
POLISHING OPERATIONS, EXPOSURE IN EXCESS OF THE NRC LIMITS MAY
INCREASE RISK OF LUNG CAN CER. THE LIGHT FROM ARC CAN CAUSE EYE
DAMAGE, INFLAMMATION OF THE MUCOUS MEMBRANE COVERING THE EYE AND
EYELIDS(FLASH BURN) AND SKIN DAMAGE. THE LIGHT TO ARC OF THE ARC
ITSELF DECOMPOSE CHLORINATED HYD ROCARBON SOLVENTS INTO DANGEROUS
CONCENTRATIONS OF TOXIC GASES SUCH AS PHOSGENE EVEN IF THE
CHLORINATED HYDROCARBON SOLVENT CONCENTRATION IS BELOW ITS TLV.
Medical Cond Aggravated by Exposure:CHRONIC RESPIRATORY DISEASES AND
ASTHMA MAY BE AGGRAVATED BY EXPOSURE TO DUST, FUME, OR MISTS. OTHER
CONDITIONS THAT MAY BE AGGRAVATED ARE NOT KNOWN AND WILL DEPEND
UPON CONDITIONS DURING ELECTRODE USE.
======================= First Aid Measures =======================
First Aid:SKIN: WASH AREA OF CONTACT WITH SOAP AND WATER, IF IRRITATION
OCCURS, SEEK MEDICAL ATTENTION. EYE: WASH (EYE) WITH A LARGE AMOUNT
OF WATER FOR AT LEAST 15 MINUTES. IF ACRATION OCCURS, SEEK MEDICAL
ATT ENTION. INHALATION: REMOVE FROM EXPOSURE. SEEK MEDICAL
ATTENTION. IF NECESSARY AID BREATHING. INGESTION: SEEK MEDICAL
ATTENTION. OTHER: WOUNDS CONTAMINATED WITH DUST, FUME, OR MIST
SHOULD BE IMMEDIATE LY AND THOROUGHLY CLEANED.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOR THE SURROUNDING FIRE. FOR TUNGSTEN DUST FIRES
USE CLASS D EXTINGUISHING MEDIA, DRY POWDERS.
Fire Fighting Procedures:FOR A TUNGSTEN DUST FIRE CONFINED TO A SMALL
AREA, USE A RESPIRATOR APPROVED FOR TOXIC DUSTS AND FUMES. FOR A
LARGE FIRE, FIRE LIGHTERS SHOULD USE SELF-CONTROLLED BREATHING
APPARATUS.
Unusual Fire/Explosion Hazard:WHEN TUNGSTEN IS HEATED IN AIR, TUNGSTEN
TRIOXIDE (TAW 5 MG/M (AS W) BEGINS TO SUBLIME ABOVE C.
================== Accidental Release Measures ==================
Spill Release Procedures:DISPOSE OF THE MATERIAL FOLLOWING ALL
APPLICABLE REGULATIONS, TUNGSTEN SCRAP AND DUST HAVE VALUE AND CAN
BE RECLAIMED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NEEDED FOR ELECTRODES AS RECEIVED. USE ONLY
NIOSH APPROVED RESPIRATOR IN ACCORDANCE WITH 29 CFR 1910.134.
Ventilation:LOCAL VENTILATION RECOMMENDED FOR DRESSING ELECTRODES.
CONFINED SPACES REQUIRE SPECIAL ATTENTION TO PROVIDE ADEQUATE
VENTIALTION.
Other Protective Equipment:WHEN WELDING WEAR FLAME RETARDANT CLOTHING
SUCH THAT SKIN IS NOT EXPOSED.
Supplemental Safety and Health
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, STRONG ACIDS, BROMINE TRIFLUORIDE, FLOURINE, IODINE
PENTAFLUORIDE AND MIXING LEAD OXIDE WITH TUNGSTEN DUST.
Stability Condition to Avoid:ELEVATED TEMPERTAURES.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF THE MATERIAL FOLLOWING ALL APPLICABLE
REGULATIONS, TUNGSTEN SCRAPS AND DUST HAVE VALUE AND CAN BE
RECLAIMED.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:BLACK AND WHITE TUNER CLEANER
CAGE:OO292
CAGE:OO292
============= Composition/Information on Ingredients =============
Ingred Name:"NO HAZARDOUS INGREDIENTS"
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:INHALATION:DIZZINESS.EYES:MILD
IRRITATION.
======================= First Aid Measures =======================
First Aid:INHALATION:MOVE TO FRESH AIR.EYES:FLUSH WITH CLEAR WATER FOR
15 MINUTES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2,DRY CHEMICAL
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:DO NOT STORE AEROSOLS IN DIRECT SUNLIGHT
OR ABOVE 120F.
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP ON SUITABLE ABSORBENT,PLACE IN
APPROPRIATE WASTE RECEPTACLE.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE IN DIRECT SUNLIGHT OR
ABOVE 120F.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:LOCAL EXHAUST.X7FT.3/MIN.
Other Protective Equipment:NONE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>400
Spec Gravity:0.865
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR WATER WHITE FLUID,NO ODOR.
Percent Volatiles by Volume:0.00
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Hazardous Decomposition Products:CO,COC12,HC1,HF
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSIGNMENT TO RECLAIMER.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:TT-L-32A TY.2 #10080 BROWN 700N48
Preparer's Name:ERNEST CARTER
CAGE:58963
CAGE:58963
============= Composition/Information on Ingredients =============
Ingred Name:XYLENE
CAS:1330-20-7
RTECS #:ZE2100000
= Wt:4.
OSHA PEL:100 PPM
ACGIH TLV:434 MG/M3;100 PPM
ACGIH STEL:651 MG/M3;150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL ISOBUTYL KETONE
CAS:108-10-1
RTECS #:SA9275000
= Wt:2.
OSHA PEL:410 MG/M3;100 PPM
ACGIH TLV:205 MG/M3;50 PPM
ACGIH STEL:307 MG/M3;75 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE
CAS:78-93-3
RTECS #:EL6475000
= Wt:13.
OSHA PEL:590 MG/M3;200 PPM
ACGIH TLV:590 MG/M3;200 PPM
ACGIH STEL:885 MG/M3;300 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL METHACRYLATE RESIN
= Wt:10.
Ingred Name:ALIPHATIC PTEROLEUM DISTILLATES
CAS:64742-89-8
Code:F
= Wt:7.
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
= Wt:1.
OSHA PEL:SEE TABLE Z-2
ACGIH TLV:188 MG/M3;50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:CELLULOSE NITRATE
< Wt:5.
Ingred Name:ISOPROPYL ALCOHOL
CAS:67-63-0
RTECS #:NT8050000
< Wt:5.
OSHA PEL:980 MG/M3;400 PPM
ACGIH TLV:983 MG/M3;400 PPM
ACGIH STEL:1230 MG/M3;500 PPM
Ingred Name:DIOCTYL PHTHALATE
CAS:117-81-7
RTECS #:TI0350000
= Wt:2.
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
ACGIH STEL:10 MG/M3
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:CYCLOHEXANONE
CAS:108-94-1
RTECS #:GW1050000
= Wt:2.
OSHA PEL:200 MG/M3;50 PPM
ACGIH TLV:100 MG/M3;25 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:DIRECT CONTACT TO EYES MAY CAUSE
IRRITATION. PROLONGED AND/OR REPEATED CONTACT MAY CAUSE SKIN
IRRITATION. INHALATION OF HIGH CONCENTRATIONS OF VAPORS MAY LEAD
TO LUNG CHANGES, NAUSEA, VOMITING, COUGH , PULMONARY IRRITATION,
AND CENTRAL NERVOUS SYSTEM DEPRESSION. INGESTION MAY CAUSE
GASTROINTESTINAL DISTURBANCES.
Effects of Overexposure:INHALATION: HIGH VAPORS MAY CAUSE DROWSINESS,
DIZZINESS, FATIGUE, FOLLOWED BY COMA. EYE: DIRECT CONTACT WITH
VAPORS MAY CAUSE IRRITATION. SKIN: PROLONGED CONTACT MAY CAUSE
IRRITATION. INGESTION: MAY CAUSE GASTROINTESTINAL DISTURBANCES.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH DISEASES INVOLVING
NERVOUS SYSTEM, LIVER AND KIDNEY.
======================= First Aid Measures =======================
First Aid:EYE CONTACT: FLUSH WITH LARGE AMOUNTS OF WATER FOR 15
MINUTES. SKIN: WASH THOROUGHLY WITH SOAP AND WATER. INGESTION:
IMMEDIATELY SEEK MEDICAL AID.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:=-4.4C, 24.F
Autoignition Temp:Autoignition Temp Text:NONE
Lower Limits:0.3%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:APPROVED GAS MASK REQUIRED FOR FIRE FIGHTING
PERSONEL. WATER MAY BE INEFFECTIVE. WATER MAY BE USED TO COOL
CONTAINERS.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH INERT MATERIAL. FLUSH AREA WITH
WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED AND UPRIGHT TO
PREVENT LEAKAGE.
Other Precautions:MAINTAIN GOOD HYGIENE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE MSHA/NIOSH APPROVED UNITS.
Ventilation:LOCAL AND MECHANICAL EXHAUST.
Other Protective Equipment:EYE BATH SAFETY SHOWER.
Work Hygienic Practices:MAINTAIN GOOD PERSONAL HYGIENE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:172 TO 724 DEG F
Melt/Freeze Pt:M.P/F.P Text:NONE
Decomp Temp:Decomp Text:NONE
Vapor Density:HEAVIER
Spec Gravity:H2O=1: 1.2
VOC Pounds/Gallon:446
VOC Grams/Liter:3.72
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:ESSENTIALLY NIL
Appearance and Odor:VISCOUS LIQUID WITH STRONG SOLVENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:FLAMES, SPARKS, SMOKING AND HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE
AND LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ACID MATRIX SPIKING SOLUTION 8270 10X 1ML, 47423
CAGE:54968
CAGE:54968
============= Composition/Information on Ingredients =============
Ingred Name:M-CRESOL, 4-CHLORO;(PHENOL,4-CHLORO-3-METHYL
4-CHLORO-3-METHYLPHENOL) (SARA III). LD50: (ORAL,RAT) 1830 MG/KG.
CAS:59-50-7
RTECS #:GO7100000
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PHENOL,0-CHLORO;(PHENOL,2-CHLORO-2-CHLOROPHENOL) (SARA
III). LD50: (ORAL,RAT) 670 MG/KG.
CAS:95-57-8
RTECS #:SK2625000
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:PHENOL,P-NITRO;(PHENOL,4-NITRO-P-NITROPHENOL) (SARA III)
CAS:100-02-7
RTECS #:SM2275000
Fraction by Wt: 0.5%
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:PHENOL,PENTACHLORO-;(PHENOL, PENTACHLORO-PENTACHLOROPHENOL)
(SARA III). LD50: (ORAL,RAT) 50 MG/KG.
CAS:87-86-5
RTECS #:SM6300000
Fraction by Wt: 0.5%
OSHA PEL:0.5 MG/M3, S
ACGIH TLV:0.5 MG/M3, S
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:PHENOL (SARA III). LD50: (ORAL,RAT) 384 MG/KG.
CAS:108-95-2
RTECS #:SJ3327000
Fraction by Wt: 5%
OSHA PEL:5 PPM, S
ACGIH TLV:5 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHANOL (SARA III). LD50: (ORAL,RAT) 5628 MG/KG.
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 260%
OSHA PEL:200 PPM, S
ACGIH TLV:200 PPM; 250 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50(ORAL,RAT):5628 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF INHALED. MAY BE FATAL IF
SWALLOWED. CONTAINS MATL(S) KNOWN TO STATE OF CA TO CAUSE CANCER.
LOW BLOOD PRESS (HYPOTENSION) DERMATITIS, BRTHG DIFFICULTY,
HEADACHE, NAUSEA, DIZZINESS, GI DISTUR BANCES, DEPRESSES CNS,
NARCOSIS, LIVER & KIDNEY DMG, RESPIRATORY FAILURE, BLINDNESS. MAY
CAUSE CORNEAL(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: INJURY. CHRONIC:PHENOL,O-CHLORO AND
PHENOL,PENTACHLORO APPEAR ON THE NAVY LISTING OF OCCUPATIONAL
CHEMICAL REPRODUCTIVE HAZARDS. SEEK CONSULTATION FROM APPROPRIATE
HEALTH PROFESSIONALS CONCE RNING LATEST HAZARD LIST INFORMATION AND
SAFE HANDLING AND EXPOSURE INFORMATION .
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH EYES W/WATER FOR AT LEAST 15 MINS. CONT MD. SKIN:
FLUSH SKIN W/LGE VOLS OF WATER. WASH CLTHG & SHOES BEFORE REUSING.
INHAL: IMMED MOVE TO FRESH AIR. GIVE O*2 IF BRTHG IS LABORED. IF
BRTHG S TOPS, GIVE ARTF RESP. CONT MD. INGEST: NEVER GIVE ANYTHING
BY MOUTH TO AN UNCON PERS. NEVER TRY TO MAKE AN UNCON PERS VOMIT.
GIVE 2 TABLESPOONS OF BAKING SODA IN GLASS OF WATER. PRESS
FINGERS(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:50.0F,10.0C
Lower Limits:6.0%
Upper Limits:36.5%
Extinguishing Media:CO*2, DRY CHEMICAL, ALCOHOL FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:THE FOLLOWING TOXIC VAPORS ARE FORMED
WHEN THIS MATL IS HEATED TO DECOMP: CARBON MONOXIDE, CARBON
DIOXIDE, FORMALDEHYDE, OXIDES OF NITROGEN, HYRDROGEN CHLORIDE.
================== Accidental Release Measures ==================
Spill Release Procedures:TAKE UP WITH ABSORBENT MATERIAL. VENTILATE
AREA. ELIMINATE ALL IGNITION SOURCES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:REFRIGERATE IN SEALED CONTAINER. KEEP
AWAY FROM OXIDIZERS. KEEP AWAY FROM IGNITION SOURCES.
Other Precautions:AVOID EYE OR SKIN CONTACT. AVOID BREATHING VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR FACE MASK WITH ORGANIC VAPOR CANISTER.
Ventilation:USE ONLY IN WELL VENTILATED AREA.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: TO BACK OF TONGUE TO INDUCE VOMITING. IMMEDIATELY
CONTACT MD.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:149F,65C
Melt/Freeze Pt:M.P/F.P Text:-144F,-98C
Vapor Pres:100
Vapor Density:1.10
Spec Gravity:.790 G/ML
Evaporation Rate & Reference:>1 (ETHER=1)
Solubility in Water:100
Appearance and Odor:CLEAR COLORLESS LIQUID
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, OXIDIZING AGENTS, CHROMIC ANHYDRIDE, LEAD PERCHLOROATE,
PERCHLORIC ACIDS, ALUMINUM & MAGNESIUM, METALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
FORMALDEHYDE, OXIDES OF NITROGEN, HYDROGEN CHLORIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY WITH ALL APPLICABLE LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ANHYDRONE, 0828
CAGE:DO811
CAGE:DO811
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:PERCHLORIC ACID, MAGNESIUM SALT; (MAGNESIUM PERCHLORATE)
CAS:10034-81-8
RTECS #:SC8925000
Fraction by Wt: 90-100%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:ULCERATION OF MUCOUS MEMBRANES,
IRRITATION OF NOSE AND THROAT, HEADACHE, COUGHING, DIZZINESS,
DIFFICULT BREATHING. SKIN:NONE IDENTIFIED. EYE:NONE IDENTIFIED.
SKIN ABSORP:NONE IDENTIFIED. INGEST: NAUSEA, VOMITING,
UNCONSCIOUSNESS. (CHRONIC) NONE IDENTIFIED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE IDENTIFIED.
======================= First Aid Measures =======================
First Aid:INGEST:IF PERSON CONSCIOUS, IMMEDIATELY GIVE LRG AMTS OF
WATER. GET MD. INHAL:CALL MD. IF INHALED, REMOVE TO FRESH AIR. IF
NOT BREATHING, GIVE ARTF RESP. IF BREATHING IS DIFFICULT, GIVE
OXYGEN. SKIN:F LUSH SKIN WITH WATER. EYE:IMMEDIATELY FLUSH WITH
PLENTY OF WATER FOR AT LEAST 15 MINUTES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Extinguishing Media:USE WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. MOVE EXPOSED CNTNRS FROM FIRE AREA IF YOU CAN W/O RISK. USE WATER
TO KEEP FIRE-EXPSD CNTNRS COOL.
Unusual Fire/Explosion Hazard:STRONG OXIDIZER. CONTACT WITH COMBUSTIBLE
MATERIALS, FLAMMABLE MATERIALS, OR POWDERED METALS CAN CAUSE FIRE
OR EXPLOSION.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE CLOTHING. KEEP COMBUSTIBLES (WOOD, PAPER, OIL, ETC) AWAY
FROM SPILLED MATERIAL. WITH CLEAN SHOVEL, CAREFULLY PLACE MATERIAL
INTO CLEAN, DRY CONTAINER AN D COVER; REMOVE FROM AREA. FLUSH SPILL
W/WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
SEPARATELY AND AWAY FROM FLAMMABLE AND COMBUSTIBLE MATERIALS.
Other Precautions:AVOID CONTACT WITH EYES, SKIN, CLOTHING. WASH
IMMEDIATELY WITH PLENTY OF WATER. CAUSES IRRITATION. STRONG
OXIDIZER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCENTRATION IS HIGH, USE AN
APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR OR DUST MASK.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
FUME OR DUST LEVELS AS LOW AS POSSIBLE. VENT HOOD.
Other Protective Equipment:UNIFORM, LAB COAT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:903F,484C
Vapor Density:7.7
Spec Gravity:2.21 (H*2O=1)
Solubility in Water:COMPLETE (100%)
Appearance and Odor:WHITE POWDER OR GRANULES.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG REDUCING AGENTS, WATER, COMBUSTIBLE MATERIALS.
Stability Condition to Avoid:MOISTURE.
Hazardous Decomposition Products:NONE IDENTIFIED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL ENVIRONMENTAL REGULATIONS. EPA HAZARDOUS
WASTE NUMBER: D003.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: AMMONIUM HYDROXIDE SOLUTIONS, LC11140
Cage: EO318
=======================================================
Contractor Summary
=======================================================
Cage: EO318
Cage: 0MX47
=======================================================
Ingredients
=======================================================
Cas: 1336-21-6
RTECS #: BQ9625000
% Wt: 4.2-50
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 7732-18-5
RTECS #: ZC0110000
% Wt: BALANCE
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
BURNS. GET MED AID AT ONCE. INGEST: GIVE
-----------------------------
ALKALI. DO NOT INDUCE VOMIT. GET MED AID AT ONCE.
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: SEE INGREDIENT 1
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: AMMONIUM HYDROXIDE IS CORR IRRITANT TO SKIN, EYE, RESP
TRACT & MUC MEMBS. CAN CAUSE SEV BURNS, EYE & LUNG INJURY AT HIGH
SOLN CONCS. ACUTE: MILD EXPOS MAY CAUSE IRRIT OF NOSE (COUGHING, SNEEZING),
RED NESS & ITCHING OF SKIN, REDNESS & IRRITOF EYES. EXPOS AT HIGHER
CONCS MAY CAUSE RESP DISTRESS, PULM (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ: EDEMA, SHOCK, CONVULSIONS,
CYANOSIS, CNS DEPRESS; CHEM BURNS TO EYES & SKIN MAY OCCUR RESULTING IN
CORROSIVE DMG INCLUDING ULCERATION & TEMPORARY BLINDNESS. INGEST MAY RSLT
IN NAUS, VOMIT, G I IRRIT, EXCESSIVE SALIVATION; IN SEVERE CASES PERFORATION,
CNS DEPRESS, SHOCK, CONVULSIONS & PULM EDEMA CAN (SUPDAT)
Medical Cond Aggravated By Exposure: SKIN AND RESPIRATORY DISEASE AGGRAVATED BY
EXPOSURE.
First Aid: INHAL: MOVE VICTIM TO FRESH AIR IMMED, GIVE ARTF RESP IF NECESSARY.
GET MED AID AT ONCE. SKIN: REMOVE CONTAM CLTHG, WASH W/SOAP & WATER.
FLUSH W/LARGE QTYS OF WATER (15-20 MIN) UNTIL CHEM IS GONE. COV ER BURNS
W/DRY STERILE DRESSING (SECURE, NOT TIGHT). GET MED AID AT ONCE. EYES: IMMED
FLUSH W/LARGE AMTS OF WATER (AT LEAST 15-20 MIN) LIFTING UPPER/LOWER LIDS
OCCASIONALLY UNTIL CHEMICAL IS
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: NEUT TO PH 7 W/DILUTE ACID OR SUITABLE AGENT. ABSORB
W/INERT ABSORB (SAND, DIATOMACEOUS EARTH), SCOOP INTO GLASS/PLASTIC CNTNR FOR
LATER DISPOSAL. VENT AREA, WASH DOWN W/WATER IF NECESSARY. AVOID BRTH G GAS,
WEAR PROT CLTHG/NIOSH APPRVD RESP EQUIP.
Neutralizing Agent: NEUTRALIZE TO PH 7 WITH A DILUTE ACID OR SUITABLE AGENT.
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS.
Handling And Storage Precautions: STORE CAPPED IN GLASS OR PLASTIC CONTAINER.
PROTECT FROM HEAT AND INCOMPATIBLE SUBSTANCES. VENTILATE AREA.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONFLAM (SUPDAT)
Lower Limits: 16% (SUPDAT)
Upper Limits: 25%
Extinguishing Media: DRY CHEMICAL, CARBON DIOXIDE, WATER SPRAY OR FOAM.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT
(FP N).
Unusual Fire/Explosion Hazard: NGELIG FIRE & EXPLOSION HAZ. ALTHOUGH NOT A
FLAM LIQ (DOT), AMMONIA GAS EVOLVED IS FLAMM, IS EYE, SKIN & RESP
IRRITANT. MOVE CNTNRS IF POSS, COOL WITH (SUPDAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT REQUIRED FOR LAB USE WHEN WORKING UNDER APPROVED
HOOD. >300PPM - NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS WITH
FULL FACEPIECE.
Ventilation: PROVIDE LOCAL EXHAUST VENTILATION TO MEET PERMISSABLE EXPOSURE
LIMITS (PEL) FOR AMMONIA GAS.
Other Protective Equipment: ANSI APPROVED EYE WASH & DELUGE SHOWER (FP N).
Work Hygienic Practices: DO NOT WEAR CONTACT LENSES WHEN WORKING WITH
CHEMICALS.
Supplemental Safety and Health: BP: (NH*3 VAPOR RELEASE). PH: ALKALINE. FL PT:
(AS AQUA AMMONIA). LEL: (FOR EVOLVED AMMONIA GAS) EXPLO HAZ: WATER. AVOID
BRTHG CORR VAPS. MATLS TO AVOID: W/STRONG OXIDIZERS, MOST METALS & THEIR
ALLOYS . EFTS OF OVEREXP: OCCUR. CHRONIC: BRONCHITIS, DERMATITIS,
CONJUNCTIVITIS CAN OCCUR.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: SUPDAT
M.P/F.P Text: <32F,<0C
Vapor Density: >AIR
Spec Gravity: <1.0
PH: SUPDAT
Evaporation Rate & Reference: 1 (WATER)
Solubility in Water: COMPLETELY SOLUBLE
Appearance and Odor: CLEAR, COLORLESS LIQUID; PUNGENT TO FAINT AMMONIA ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEATING EVOLVES AMMONIA GAS (NH*3).
Materials To Avoid: REACTS EXOTHERMICALLY W/ACIDS, REACTS W/HYPOCHLORITES,
HALOGENS, SODIUM HYDROXIDE & GALVANIZED SURFS. REACTS (SUPDAT)
Hazardous Decomposition Products: AMMONIA GAS IS RELEASED WHICH MAY DECOMPOSE
ABOVE 842F TO HYDROGEN AND NITROGEN GASES.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: AMMONIUM HYDROXIDE SOLUTIONS, LC11140
Cage: EO318
Assigned IND: Y
Company Name: LABCHEM INC
Street: 200 WILLIAM PITT WAY
Zipcode: 15238
Label Required IND: Y
Date Of Label Review: 11/09/1998
Status Code: C
Label Date: 11/09/1998
Origination
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Severe
Contact Hazard: Severe
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: MILD EXPOSURE MAY CAUSE IRRITATION OF NOSE
(COUGHING, SNEEZING), REDNESS AND ITCHING OF SKIN, REDNESS AND IRRITATION OF
EYES. EXPOSURE AT HIGHER CONCENTRATIONS MAY CAUSE RESPIRATORY DISTRESS, P
ULMONARY EDEMA, SHOCK, CONVULSIONS, CYANOSIS, CNS DEPRESSION. CHEMICAL BURNS
TO EYES AND SKIN MAY OCCUR RESULTING IN CORROSIVE DAMAGE INCLUDING ULCERATION
AND TEMPORARY BLINDNESS. INGESTION MAY RESULT IN NAUSEA, VOMITING, GASTRIC
IRRITATION, EXCESSIVE SALIVATION; IN SEVERE CASESPERFORATION, CNS DEPRESSION,
SHOCK, CONVULSIONS AND PULMONARY EDEMA CAN OCCUR. CHRONIC: BRONCHITIS,
DERMATITIS, CONJUNCTI VITIS.
=======================================================
| 1 |
gloves_mandatory
|
=======================================================
Product ID: SILVER SOLID SCENTAIRE
Cage: IC
Proprietary Ind: Y
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: IC
Assigned Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: IC
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Explanation Of Carcinogenicity: NONE
First Aid: EYES: FLUSH W/PLENTY OF COOL RUNNING WATER. REMOVE CONTACT LENSES
& CONTINUE FLUSHING. SKIN: WASH THOROUGHLY W/SOAP & WATER.
INGESTION: DRINK WATER. DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: CLEANUP; PICKUP EXCESS. DISCARD INTO DISPOSABLE
CONTAINER.
Waste Disposal Methods: DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
SMALL AMOUNTS MAY BE SEWERED.
Handling And Storage Precautions: STORE IN A COOL, DRY, VENTILATED AREA.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: >200F
Fire Fighting Procedures: NONE
Unusual Fire/Explosion Hazard: PRODUCT DOESN'T SUPPORT COMBUSTION.
=======================================================
Control Measures
=======================================================
Work Hygienic Practices: NO REQUIREMENTS BEYOND STANDARD INDUSTRIAL HYGIENE
PRACTICES.
=======================================================
Physical/Chemical Properties
=======================================================
M.P/F.P Text: 150F
Spec Gravity: 1.01
Solubility in Water: 100%
Appearance and Odor: GREEN COLOR W/CHARACTERISTIC FRAGRANCE ODOR
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: STRONG ACIDS, ALKALIS, OXIDIZING AGENTS.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: LABEL COVERED UNDER EPA REGS - HAZCOM LABEL NOT AUTHORIZED
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:925/165902
CAGE:01102
CAGE:81133
CAGE:01102
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMED.SKIN:WASH W/SOAP IMMED.INHAL:REMOVE
TO FRESH AIR,GIVE ART.RESPIR.AS NEEDED.INGEST:GET MEDICAL ATTN.GIVE
LARGE QTY OF SALT WATER,INDUCE VOMITING,BUT DO NOT MAKE UNCONSCIOUS
PER SON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE AND NOTIFY PROPER AUTORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS.CAUSES STILLBIRHTS.IRRIATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:V1
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CORROSION PREVENTIVE COMPOUND
CAGE:27978
CAGE:27978
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENT 140 HI FLASH ALIPHATIC HYDROCARBON BLEND
Fraction by Wt: 12.5%
OSHA PEL:1000 PPM
Ingred Name:INHIBITOR BLEND INCLUDING THE BARIUM SOAP OF AN OXYGENATED
HYDROCARBON
Fraction by Wt: 12.5%
Ingred Name:SOLVENT FREON 113
Fraction by Wt: 75%
ACGIH TLV:1000 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:LIGHT HEADEDNESS, GIDDINESS, SHORTNESS
OF BREATH, POSSIBLE NARCOSIS, POSSIBLE CARDIAC ARRHYTHMIAS AT HIGH
CONCENTRATIONS.
Effects of Overexposure:LIGHT HEADEDNESS, GIDDINESS, SHORTNESS OF
BREATH, POSSIBLE NARCOSIS, POSSIBLE CARDIAC ARRHYTHMIAS AT HIGH
CONCENTRATIONS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR, CALL A PHYSICIAN. DO NOT
GIVE EPINEPHINE OR SIMILAR DRUGS. SKIN AND/OR EYES: FLUSH WITH
WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:163 F/ 73 C
Extinguishing Media:MECHANICAL FOAM, DRY CHEMICALS, WATER FOG, CO2.
Fire Fighting Procedures:STRAIGHT WATER STREAM WOULD SPREAD OIL FIRES.
Unusual Fire/Explosion Hazard:VAPOR ACCUMULATION WOULD FLASH AND/OR
EXPLODE IF IGNITED.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA-ESPECIALLY LOW PLACES WHERE
HEAVY VAPORS MIGHT COLLECT. REMOVE FLAMES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE CONTAINERS IN A CLEAN, DRY AREA.
DO NOT HEATABOVE 125 F.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE IARI MASK IN HIGH CONCENTRATIONS.
Ventilation:USE LOCAL EXHAUST WHEN LARGE AMOUNTS ARE RELEASED.
Other Protective Equipment:NONE.
Work Hygienic Practices:READ ALL LABELS CAREFULLY BEFORE USING.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
HCC:V2
Boiling Pt:B.P. Text:117 F-390 F
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:334 MMHG
Vapor Density:6.5(AIR=1)
Spec Gravity:1.25-1.30 H2O=1
Evaporation Rate & Reference:0.3
Solubility in Water:NEGLIGIBLE.
Appearance and Odor:DARK AMBER WITH ORGANIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALI OR ALKALINE EARTH METALS-POWERED AL, ZN, BE, ETC.
Stability Condition to Avoid:OPEN FLAMES OR HIGH TEMPERATURE.
Hazardous Decomposition Products:HYDROCHLORIC AND HYDROFLORIC
ACIDS-POSSIBLE CARBONYL HALIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:RECLAIM BY DISTILLATION.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:HYDROCHLORIC ACID (MURIATIC ACID), 22*
Preparer's Name:DAVID W. KANANEN
CAGE:6H472
CAGE:6H472
============= Composition/Information on Ingredients =============
Ingred Name:HYDROCHLORIC ACID; (MURIATIC ACID) (HYDROGEN CHLORIDE 22*
(22* IS CONC VALUE (DEGREE BAUME) RELATED TO SPEC GRAV)(JJMA))
CAS:7647-01-0
RTECS #:MW4025000
Fraction by Wt: 32%
OSHA PEL:5 PPM, C
ACGIH TLV:5 PPM, C
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CAUSES SEVERE SKIN AND EYE BURNS. MAY
BE FATAL IF INHALED OR SWALLOWED. VAPORS ARE EXTREMELY IRRITATING.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE/SKIN: FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES
WHILE REMOVING CONTAMINATED CLOTHING AND SHOES. CALL MD. INGESTION:
DO NOT INDUCE VOMITING-DRINK LARGE VOLUMES OF WATER, MILK, MILK OF
MAGN ESIA, OR BEATEN EGG WHITES WITH WATER. DO NOT GIVE EMETICS,
BAKING SODA, OR CARBONATES. INHALATION: REMOVE TO FRESH AIR. GIVE
ARTIFICIAL RESPIRATION IF BREATHING HAS STOPPED. CALL MD.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE EXTINGUISHING MEDIA SUITABLE FOR SURROUNDING
FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . COOL TANKS WITH WATER IF EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:HYDROCHLORIC ACID IS NOT FIRE HAZ ITSELF,
BUT MAY CAUSE FIRE IF REACTING W/OTHER MATERIALS. EXPLO CONC OF
HYDROGEN GAS MAY ACCUMULATE INSIDE METAL EQUIPMENT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION AND CONTAIN SPILL.
STAY UPWIND OF SPILL. IN SPILL AREA WEAR NIOSH/MSHA APPROVED SCBA
AND FULL ACID PROTECTIVE CLOTHING INCLUDING RUBBER BOOTS. AVOID
BREATHING VAPORS.
Neutralizing Agent:SODA ASH OR SLAKED LIME.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. PROTECT AGAINST
PHYSICAL DAMAGE. KEEP CONTAINERS OUT OF DIRECT SUNLIGHT AND AWAY
FROM HEAT.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. NEVER USE PRESSURE TO
EMPTY CONTAINERS. REFER TO 29 CFR 1910.1200.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED CARTRIDGE FILTER-CHARCOAL
TYPE.
Ventilation:LOCAL EXHAUST-DIRECT HOODS AND DOWN DRAFT SYSTEM.
MECHANICAL (GENERAL)-TO HANDLE GASES HEAVIER THAN AIR.
Other Protective Equipment:WEAR CHEMICAL RESISTANT CLOTHING WHILE
HANDLING OR TRANSFERRING CONTENTS. EMERGENCY EYE WASH AND DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPECIFIC GRAVITY: 1.1924 (H*2O=1).
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:230F,110C
Vapor Pres:35 @ 25C
Vapor Density:127
Spec Gravity:1.1600-(SUPDAT)
Evaporation Rate & Reference:>1 (ETHYL ETHER=1)
Solubility in Water:INFINITE
Appearance and Odor:CLEAR, COLORLESS TO SLIGHTLY YELLOW LIQUID WITH A
SHARP PUNGENT ODOR.
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CORROSIVE TO MOST METALS WITH THE EVOLUTION OF HYDROGEN GAS.
Stability Condition to Avoid:AVOID MATERIALS SUCH AS CYANIDES, SULFIDES
AND FORMALDEHYDES. HEATING CAUSES RELEASE OF HYDROGEN CHLORIDE.
Hazardous Decomposition Products:HYDROGEN CHLORIDE VAPOR. HYDROGEN GAS.
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH THOROUGHLY WITH WATER APPLIED TO ENTIRE
SPILL. NEUTRALIZE WASHINGS WITH SODA ASH OR SLAKED LIME BEFORE
DISCARDING TO SEWER. OBSERVE ALL LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:URALANE 5750 A/B
Kit Part:Y
FERNANDO RD W
CAGE:GO766
POLYMERS
CAGE:99384
CAGE:GO766
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <15%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: UNK
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL DIPHENYL DIISOCYANATE; TLV DATA PER MFG MSDS.
Fraction by Wt: UNK
ACGIH TLV:0.02 PPM
Ingred Name:NON-AQUEOUS SOLUTION, HAZARD UNKNOWN, UNIDENTIFIED
INGREIENTS.
Fraction by Wt: UNK
Ingred Name:METHYL FORMATE
CAS:107-31-3
RTECS #:LQ8925000
Fraction by Wt: <1.0%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
===================== Hazards Identification =====================
Effects of Overexposure:SOLVENT TOXICITY & IRRITATION (PER MFG,
UNIDENTIFIED SOLVENT HAS TLV OF 100 PPM);ASTHMATIC SPASM.
======================= First Aid Measures =======================
First Aid:INHALE:REMOVE TO FRESH AIR, GIVE CPR/O*2 IF
NEED;EYES/SKIN:FLUSH W LG AMTS H*2O FOR 15 MIN;INGEST:RINSE
MOUTH;GET MEDICAL ATTENTION FOR EYES, BREATHING DIFFICULTY, OR
OTHER SYMPTOMS OF OVEREXPOSURE (I NCLUDING ASTHMATIC SPASMS)
===================== Fire Fighting Measures =====================
Flash Point:45F,7.2C COC
Extinguishing Media:CO*2, FOAM, DRY CHEM & H*2O FOG.
Fire Fighting Procedures:WEAR SELF-CNTND BRTHG APP:H*2O SPRAY TO COOL
CONTR.
Unusual Fire/Explosion Hazard:MATL MAY/MAY NOT BURN. CONTAINER MAY
EXPLODE IN HEAT OF FIRE.FIRE MAY YIELD TOXIC GASES.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE UNPROTECTED PERSONS. ELIM IGNITION
SOURCES. STOP LEAK. H*2O SPRAY COOL CONT/DIVERT SPILL FROM
FIRE/HEAT. PROVIDE VENTILATION. ABSORB W/COMMERCIAL
ABSORBENT,SHOVEL INTO METAL DRUMS:LG SPILL:DI KE W COMMERCIAL
ABSORBENT,PUMP INTO COVERED DRUMS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENT,LOW FIRE
RISK AREA. PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL CONTACT.
KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:MAINTAIN STRICT HYGIENE,USE PROTECTIVE SKIN CREAMS,
REMOVE & WASH CONTAMINATED CLOTHING;PROHIBIT EMPLOYEES W
RESPIRATORY PROBS. FROM AREA;PRODUCT CRYSTALLIZES AT ROOM TEMP,
REDISSOLVE AT 150F.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ORGANIC VAPOR OR SUPPLIED AIR MASK,SCBA IF
EXPOSED OR IN CLOSED ROOM
Ventilation:MECHANICAL, LOCAL(SUGGEST PAINT SPRAY BOOTH);SEE SUP. DATA
Other Protective Equipment:FULL WORK CLOTHING TO PREVENT REPEATED OR
PROLONGED CONTACT.
Supplemental Safety and Health
PART A OF 2 PART PRODUCT. THIS PART IS BASE. SEE P/N FOR PART
B(CATALYST). PRODUCT IS TYPE UR OF MIL-I-46058. USE WITH
VENTILATION THAT DRAWS FUMES AWAY FROM WORKERS.KEY1:J1.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:DECOMPOSES
Vapor Pres:0.1
Spec Gravity:1.2
Evaporation Rate & Reference:<1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR LIQUID MIXTURE;SOLVENT ODOR.
Percent Volatiles by Volume:9.5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, IGNITION SOURCES
Hazardous Decomposition Products:NONE NOTED, BUT EXPECT CO, CO*2, H*2O
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED CONTAINERS PENDING DISPOSAL.
HANDLE AND DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE AND LOCAL REGULATIONS. MFG SUGGESTS
INCINERATION OR BURY IN APPROVED LANDFILL;WASH RESIDUE W
DETERGENT, EXCESS WATER.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: EASY-FLO 45
Cage: 91874
Box: 638
=======================================================
Contractor Summary
=======================================================
Cage: 91874
=======================================================
Ingredients
=======================================================
FINELY-DIVIDED FORM & TO PVNT EYE INJURY FROM
-----------------------------
FILTER LENS (SHADE #3 OR #4) ARE RECOMMENDED.
-----------------------------
-----------------------------
WELDING & CUTTING" (AWS, MIAMI, FL 33135).
-----------------------------
Cas: 7440-43-9
RTECS #: EU9800000
% Wt: 5-24
OSHA PEL: 5 MG/M3 (MFR)
ACGIH TLV: 0.01 MG/M3 DUST
EPA Rpt Qty: 10 LBS
DOT Rpt Qty: 10 LBS
------------------------------
Cas: 7440-50-8
RTECS #: GL5325000
% Wt: 15-45
OSHA PEL: 0.1MG/M3 FUME;1 DUST
ACGIH TLV: 0.2MG/M3 FUME
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 7440-22-4
RTECS #: VW3500000
% Wt: 20-50
OSHA PEL: 0.01 MG/M3
ACGIH TLV: 0.1 MG/M3
EPA Rpt Qty: 1 LB
DOT Rpt Qty: 1 LB
------------------------------
Cas: 7440-66-6
RTECS #: ZG8600000
% Wt: 16-30
OSHA PEL: 10 MG/M3 (ZNO)
ACGIH TLV: 10 MG/M3 (ZNO)
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
HUMAN:LUNG, PROSTATE, RENAL SYSTEM EFFECTS.
-----------------------------
& ULCERATION OF CORNEA. INGEST:INGEST OF
-----------------------------
ABDOM PAIN, HEMORR, DIARR. CHRONIC:INHAL:
-----------------------------
DISCOLORATION OF TEETH, MICROFRACTURES, KIDNEY
-----------------------------
SPLEEN, PANCREAS & BRAIN. ING 3:EXPOS MAY
-----------------------------
MEMBS & RESP TRACT. ING 4:EXPOS HAS NOT
-----------------------------
INGEST:LONG-TERM INGEST MAY PRDCE DMG TO LIVER,
-----------------------------
& BRAIN. ING 1 HAS ALSO CAUSED
-----------------------------
-----------------------------
MUSCULOSKELETAL SYSTEM.
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: YES
Effects of Exposure: ACUTE:INHAL:ING 1:EXPOS MAY PRDCE PNEUM, TRACHEOBRONCH
& PULM EDEMA. ING 2:EXPOS MAY CAUSE RESP TRACT IRRIT, FEVER, MUSCLE ACHE,
CHILLS, COUGH, WEAK & METALLIC TASTE. ING 4:EXPOS MAY CAUSE RESP TRACT
IRRIT & "METAL FUME FEVER", WHICH IS CHARACT BY ONE/MORE OF FOLLOWING
SYMPS:METALLIC TASTE, DRY THROAT,(EFTS OF OVEREXP)
Explanation Of Carcinogenicity: CADMIUM:IARC MONOGRAPHS, SUPP, VOL 7, PG 139,
1987:GRP 2A. NTP 6TH ANNUAL RPT ON CARCINS, 1991:ANTIC TO BE
Signs And Symptions Of Overexposure: HLTH HAZ:COUGH, CHILLS, FEVER, TIGHTNESS
OF CHEST, DYSPNEA, HDCH, NAUS, VOMIT & FATG. SKIN:CONT W/THIS MATL IN
SOLID FORMS IS NOT KNOWN TO BE HAZ. IN FINELY-DIVIDED FORM, CONT MAY PRDCE
LOCALIZED IRRI T, LOCALIZED ARGYRIA(FROM ING 3), &/OR DISCOLORATION &
CONT DERM(FROM ING 2). EYES:EXPOS TO THIS MATL IN FINELY-
Medical Cond Aggravated By Exposure: PRE-EXISTING PULM DISEASES (E.G., BRONCH,
EMPHYSEMA) MAY BE AGGRAVATED BY INHAL EXPOS TO THIS MATL, PARTICULARLY AS
FUME. ADDNLY, EXPOS TO ING 1 BY INHAL &/OR INGEST MAY AGGRAVATE
PRE-EXISTING(SUPDAT)
First Aid: INHAL:REMOVE SUBJECT FROM CONTAM AREA, ADMIN OXYGEN & SEEK MED
ATTN. KEEP SUBJECT WARM & AT REST. PERFORM ARTF RESP IF BRTHG HAS
STOPPED. SKIN:REMOVE CONTAM CLTHG. WASH AFFECTED AREA W/LG QTYS OF WATE R FOR
AT LST 5 MINS. SEEK MED ATTN IF NEC. EYES:FLUSH AFFECTED AREAS W/WATER FOR AT
LST 15 MINS. SEEK MED ASSISTANCE IF NEC. INGEST:IF SUBJECT IS CONSCIOUS,
INDUCE VOMIT. IF UNCON/CONVULSIVE,
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: CLEAN UP SPILLED MATERIAL SO AS TO MINIMIZE
DISPERSION OF DUST. WET SWEEPING OR VACUUMING USING HEPA FILTRATION ARE
RECOMMENDED METHODS. REPORTABLE QTYS:ING 1:1 LB; ING 2:5000 LBS; ING 3:1000
LBS; ING 4:1000 LBS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS (FP N). RETURN TO MANUFACTURER FOR RECLAIM.
Handling And Storage Precautions: DO NOT STORE AT HIGHLY-ELEVATED TEMPERATURES
OR IN PROXIMITY TO INCOMPATIBLE MATLS. DANGER. CONTAINS CADMIUM. CANCER
HAZARD. AVOID CREATING DUST.
Other Precautions: CAN CAUSE LUNG & KIDNEY DISEASE. BRAZING ALLOYS MAY BE
USED W/SEPARATELY-APPLIED FLUX WHICH, WHEN HEATED, MAY EMIT IRRIT &/OR
TOX GASES & FUMES. CONSULT MSDS FOR SPECIFIC FLUX IN USE TO DETERMINE ITS
HAZS & APPROP PROT MEASURES. FOR
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: USE DRY POWDER. DO NOT USE WATER.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: IN FINELY-DIVIDED FORM, THIS MATL MAY IGNITE
WHEN EXPOS TO FLAME/BY RXN W/INCOMPAT MATLS. FIRES/EXPLOS INVOLVING THIS MATL
MAY RELS POTNTLY TOX (SUPP DATA)
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF EXPOSURE LEVELS EXCEED OSHA PEL(S), WEAR A
NIOSH/MSHA APPROVED RESPIRATOR HAVING A PROTECTION FACTOR APPROPRIATE TO THE
AIRBORNE CONCENTRATIONS OF THE CONTAMINANTS GENERATED.
Ventilation: USE MECH LOC EXHST VENT ADEQ TO MAINTAIN AIRBORNE CONCS OF ALL
COMPONENTS & THEIR DECOMP PRODS TO W/IN THEIR (SUPDAT)
Other Protective Equipment: WEAR APPROP PROT CLTHG TO PVNT SKIN INJURIES FROM
HAZS OF BRAZING &/OR FOR PRLNG/RPTD CONT W/FINELY-DIVIDED
Work Hygienic Practices: TO AVOID INGESTION OF MATERIAL, WASH HANDS & FACE
BEFORE EATING, DRINKING OR CONSUMPTION OF TOBACCO.
Supplemental Safety and Health: MP:>1110F,>600C. EXPLO HAZ:EMISSIONS OF
METAL/METAL OXIDE FUMES. MATLS TO AVOID:PEROXIDES; PEROXYFORMIC ACID;
CHLORINE & FLUORINE; PERMONOSULFURIC ACID; CHLORATES; CRO*3; MN & CA
CHLORIDES; CS*2; HYDR AZINE MONONITRATE; NITROBENZENE; FE(CO)*5; SELENINYL
BROMIDE. VENT:RESPECTIVE OSHA PELS.
=======================================================
Physical/Chemical Properties
=======================================================
M.P/F.P Text: SUPP DATA
Spec Gravity: 8.79-9.53
Solubility in Water: INSOLUBLE
Appearance and Odor: LIGHT-YELLOW METAL IN FORM OF WIRE, ROD, STRIP,
PWDR/PREFORMED SHAPES; ODORLESS
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: STRONG OXIDIZERS; SE; TE; MG; ACETYLENE; NH*3; HNO*3;
AZIDES, ETHANOL, ETHYLENE IMINE; CF*3; INORGANIC & ORG (SUPP DATA)
Hazardous Decomposition Products: HEATING AT BRAZING TEMPERATURES MAY LIBERATE
OXIDES OF METALS AS FUME.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: EASY-FLO 45
Cage: 91874
Company Name: LUCAS-MILHAUPT INC A HANDY & HARMAN CO
Street: 5656 SOUTH PENNSYLVANIA AVENUE
Zipcode: 53110
Label Required IND: Y
Date Of Label Review: 03/25/1994
Status Code: C
Label Date: 03/25/1994
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: CONTAINS CADMIUM. AVOID CREATING DUST. STORE IN A COOL
PLACE AWAY FROM INCOMPATIBLE MATERIALS. ACUTE:INHALATION MAY CAUSE METAL FUME
FEVER W/SYMPTOMS OF DRY THROAT, COUGH, CHILLS, FEVER, NAUSEA, VOMIT ING,
RESPIRATORY TRACT IRRITATION, PNEUMONITIS & PULMONARY EDEMA. INGESTION
MAY PRODUCE GASTRIC IRRITATION, VOMITING, ABDOMINAL PAIN, HEMORRHAGE &
DIARRHEA. SKIN CONTACT W/DUST CAN CAUSE IRRITATION, D ISCOLORATION &
DERMATITIS. EYE CONTACT W/DUST MAY CAUSE IRRITATION, CONJUNCTIVITIS &
ULCERATION OF CORNEA. CHRONIC:CANCER HAZARD. CONTAINS CADMIUM WHICH IS LISTED
AS A HUMAN LUNG CARCINOGEN (FP N). CA N CAUSE LUNG & KIDNEY DAMAGE.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:G641
Preparer's Name:D A POLSINELLI
CAGE:GESIL
CAGE:GESIL
CAGE:01139
============= Composition/Information on Ingredients =============
Ingred Name:ZINC OXIDE (SARA 313) (CERCLA)
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: 60-80%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:DOW CORNING 200 FLUID; (POLYDIMETHYLSILOXANE)
CAS:63148-62-9
RTECS #:JJ6484500
Fraction by Wt: 10-30%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:SKIN:IRRITATION IS NOT EXPECTED,
BUT MAY OCCUR IN CERTAIN SENSITIVE INDIVIDUALS. INHALATION:DUST
HAZARD MAY BE CREATED IF, UNDER CONDITIONS OF USE, SOLID PARTICLES
ARE SEPARATED FROM POLYMERIC M ATRIX. EYE:CAUSES MODERATE
IRRITATION. CHRONIC:METAL FUME FEVER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INGEST:DO NOT INDUCE VOMIT. SLOWLY DILUTE WITH 1-2 GLASSES OF
WATER/MILK & SEEK MED ATTN. NEVER GIVE ANYTHING BY MOUTH TO UNCON
PERSON. RINSE MOUTH WITH WATER SEVERAL TIMES. SKIN:WASH W/SOAP &
WATER. INHAL:MOVE PERSON TO FRESH AIR. EYES:IMMED FLUSH W/PLENTY
OF WATER FOR @ LEAST 15 MINS & GET MED ATTN IF IRRIT PERSISTS.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>500F,>260C
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:NONE KNOWN. USE NIOSH/MSHA APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE, SCRAPE/SOAK UP IN INERT MATL & PUT IN
CNTNR FOR DISPOSAL. WASH WALKING SURFACES W/DETERGENT & WATER TO
REDUCE SLIPPING HAZARD. WEAR PROPER PROT EQUIP AS SPECIFIED IN PROT
EQUIP SECTION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH EYES.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE KNOWN. NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE KNOWN.
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>600F,>316C
Vapor Pres:<1 @ 20C
Vapor Density:NEGLIGIBLE
Spec Gravity:2.6 (WATER =1)
Evaporation Rate & Reference:NEGLIG (BUTYL ACETATE =1)
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE PASTE, ODORLESS
Percent Volatiles by Volume:<1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONTACT WITH OXIDIZING AGENTS.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
SILICON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:PHOSPHORUS PENTOXIDE, POWDER, (SUPP DATA)
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:ING 05: PENTAFLUORIDE, CHLORINE TRIFLUORIDE, PERCHLORIC
ACID & OXYGEN DIFLUORIDE.
RTECS #:9999999ZZ
Ingred Name:PHOSPHORUS PENTOXIDE (SARA III)
CAS:1314-56-3
RTECS #:TH3945000
Fraction by Wt: 98%
Ingred Name:ADDNL INFO: RXN WITH 95% FORMIC ACID CAUSED RAPID EVOLUTION
OF CO. DRY MIX W/SODIUM OXIDE, CALCIUM OXIDE REACT (ING 03)
RTECS #:9999999ZZ
Ingred Name:ING 02: VIOLENTLY IF WARMED OR MOISTENED. MIXTURE WITH
SODIUM CARBONATE IS INITIATED BY STRONG LOCAL HEATING. (ING 04)
RTECS #:9999999ZZ
Ingred Name:ING 03: ADDITION OF PHOSPHOROUS PENTOXIDE TO 3-PROPYNOL
RSLTS IN IGNIT. REACTS VIGOROUSLY W/HYDROGEN FLUORIDE, (ING 05)
RTECS #:9999999ZZ
Ingred Name:ING 04: VIOLENTLY WITH IODIDES, SULFIDES & EXPLOSIVELY WITH
CALCIUM WHEN HEATED. INCOMPATIBLE WITH: BROMINE (ING 06)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE SUPP DATA
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: HARMFUL IF SWALLOWED OR
INHALED. MATERIAL IS EXTREMELY DESTRUCTIVE TO TISSUE OF THE MUCOUS
MEMBRANES AND UPPER RESPIRATORY TRACT, EYES AND SKIN. INHALATION
MAY BE FATAL AS A RESULT OF SPASM, IN FLAMMATION AND EDEMA OF THE
LARYNX AND BRONCHI, CHEMICAL PNEUMONITIS AND PULMONARY EDEMA.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:MAY INCLUDE BURNING SENSATION, COUGHING,
WHEEZING, LARYNGITIS, SHORTNESS OF BREATH, HEADACHE, NAUSEA AND
VOMITING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: IMMED FLUSH W/COPIOUS AMOUNTS OF WATER FOR AT
LEAST 15 MIN WHILE REMOVING CONTAM CLOTHING & SHOES. ASSURE
ADEQUATE FLUSHING OF THE EYES BY SEPARATING THE EYELIDS W/FINGERS.
INHAL: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN. CALL MD. WASH
CONTAM CLOTHING BEFORE REUSE. DISCARD CONTAMINATED SHOES. INGEST:
CALL MD IMMED .
===================== Fire Fighting Measures =====================
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE TO SURROUNDING
FIRE CONDITIONS. DO NOT USE WATER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT TO PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.EVACUATE AREA.
WEAR NIOSH/MSHA APPROVED SCBA, RUBBER BOOTS AND HEAVY RUBBER
RAISING DUST. VENTILATE A REA AND WASH SPILL SITE AFTER MATERIAL
PICKUP IS C
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.NONE SPECIFIED BY
MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.KEEP
TIGHTLY CLOSED. DO NOT ALLOW CONTACT WITH WATER. STORE UNDER
NITROGEN. STORE IN A COOL, DRY PLACE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.DO NOT BREATHE DUST.
DO NOT GET IN EYES, ON SKIN OR CLOTHING. AVOID PROLONGED OR
REPEATED EXPOSURE. CORROSIVE. TOXIC.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.WEAR APPROPRIATE
NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:NONE SPECIFIED BY MANUFACTURER.USE ONLY IN A CHEMICAL FUME
HOOD.
Other Protective Equipment:RUBBER BOOTS AND OTHER PROTECTIVE CLOTHING,
SAFETY SHOWER AND EYE BATH
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER USE AND BEFORE
EATING, DRINKING, SMOKING OR USING SANITARY FACILITIES .
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO: 98+%, A.C.S. REAGENT. BP: SUBLIMES AT 360C .
LD50-LC50 MIX: LC50: (IHL/RAT)=1217 MG/M3, (IHL/MUS)=271 MG/M3,
(IHL/RBT)=1689 MG/M3, (IHL/GPG)=61 MG/M3. WASTE DISP METH:WHICH
CAN BE CONTROLLED BY THE RATE OF ADDITION. DISPOSE I/A/W FEDERAL,
STATE & LOCAL LAWS.
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:SUPP DATA
Vapor Pres:10.0 @238C
Vapor Density:4.9
Spec Gravity:2.38
Solubility in Water:VERY SOLUBLE
Appearance and Odor:WHITE POWDER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
SODIUM, ALUMINUM, POTASSIUM, AMMONIA, PEROXIDES, MAGNESIUM. REACTS
VIOLENTLY WITH WATER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NATURE OF DECOMPOSITION PRODUCTS NOT
KNOWN. PHOSPHORIC ACID .
==================== Disposal Considerations ====================
Waste Disposal Methods:NONE SPECIFIED BY MANUFACTURER.SM QTYS:
CAUTIOUSLY ADD TO LG STIRRED EXCESS OF H*2O. ADJUST PH TO NEUT,
SEPARATE ANY INSOL SOLIDS/LIQS & PKG FOR HAZ WASTE DISP. FLUSH AQ
SOLN DOWN DRAIN W/PLENTY OF H* 2O. THE HYDROLYSIS/NEUTRALIZATION
RXNS MAY GENERAT
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:FA11/709
CAGE:JO867
CAGE:81831
CAGE:JO867
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART. RESPIR.AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UN CONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: BC-20 BLACK INK CARTRIDGE
Cage: 1BA63
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 08YZ7
Cage: 1BA63
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHALATION: EXPECTED TO BE A LOW HAZARD FOR RECOMMENDED
HANDLING. EYE: NO SPECIFIC HAZARD KNOWN. MAY CAUSE TRANSIENT IRRITATION.
SKIN: EXPECTED TO BE LOW HAZARD FOR RECOMMENDED HANDLING. INGESTION: MA Y BE
HARMFUL IF SWALLOWED.
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHALATION: IF SYMPTOMMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: ANY MATERIAL THAT CONTACTS THE EYE
SHOULD BE WASHED OUT IMMEDIATELY WITH WATER FOR AT LEAST 15 MINUTES.GET
MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH SOAP AND WATER. GET
MEDICAL ATTENTION IF SYMPTOMS OCCUR. INGESTION: DRINK 1-2 GLASSES OF WATER.
GET IMMEDIATE MEDICAL ATTENTION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: USE ABSORBENT MATERIAL TO SOAK UP SPILLED EXCESS INK.
THIS MATERIAL HAS NOT BEEN TESTED FOR ENVIRONMENTAL EFFECTS. IN A SPILL
SITUATION THIS MATERIAL MAY BE VISUALLY UNPLEASANT; HOWEVER, IT IS NOT EXP
ECTED TO CAUSE ANY ADVERSE ENVIRONMENTAL EFFECT.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: INCINERATE/LANDFILL; CAN BE INCINERATED WHEN IN
COMPLIANCE W/LOCAL REGS. DISCHARGE, TREATMENT/DISP MAY BE SUBJECT TO FED,
STATE/LOCAL LAWS. RCRA STATUS: IF DISCARDED IN ITS PURCHASED FORM, THIS PROD
W OULD NOT BE HAZ WASTE EITHER BY LISTING(SUPDAT)
Handling And Storage Precautions: USE WITH ADEQUATE VENTILATION. WASH
THOROUGHLY AFTER HANDLING. KEEP FROM CONTACT W/OXIDIZING MATLS. KEEP
CONTAINER CLOSED. STORE IN COOL, VENT AREA.
Other Precautions: U.S./CANADA LABEL STATEMENTS:LOW HAZARD FOR REC HANDLING.
USE W/ADEQUATE VENT. IN CASE OF FIRE:USE WATER SPRAY, CARBON DIOXIDE (CO*2),
OR DRY CHEMICAL. IN CASE OF SPILL:USE ABSORBENT MATL TO SOAK UP I NK. SPILL
AREA MAY BE FLUSHED WITH H*2O.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: WATER SPRAY, CARBON DIOXIDE (CO*2), DRY CHEMICAL.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: HAZARDOUS COMBUSTION PRODUCTS: CARBON DIOXIDE,
CARBON MONOXIDE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE SHOULD BE NEEDED. NIOSH APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN (FP N).
Ventilation: GOOD VENTILATION (TYPICALLY 4-6 ROOM VOLUMES PER HR) SHOULD BE
USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: NORMAL WASHING FACILITIES.
Supplemental Safety and Health: USERS OF "L" VERSION OF SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). PH: 8 TO 10. WASTE DISP METH: OR CHARACT.
HOWEVER, UNDER RCRA, IT IS THE RESPONSIBILITY OF THE END-USER TO DETERM AT
TIM E OF DISP, WHETHER A MATL CONTAINING THE PROD/DERIVED FROM THE PROD
SHOULD BE CLASSIFIED AS HAZ WASTE. 40 CFR 261.20-24.
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 1.4 (H*2O = 1)
PH: SUPDAT
Solubility in Water: MISCIBLE
Appearance and Odor: LIQUID, BLACK, SLIGHT SWEET-ALCOHOLIC ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: COMBUSTION WILL PRODUCE CARBON DIOXIDE AND
POSSIBLE TOXIC CHEMICALS SUCH AS CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: BC-20 BLACK INK CARTRIDGE
Cage: 1BA63
Company Name: CANON USA INC
Street: ONE CANON PLAZA
Zipcode: 11042
Label Required IND: Y
Date Of Label Review: 09/06/1996
Status Code: C
Label Date: 09/06/1996
Origination Code: G
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: DO NOT INGEST. ACUTE: INHALATION: EXPECTED TO BE A LOW
HAZARD FOR RECOMMENDED HANDLING. EYE: NO SPECIFIC HAZARD KNOWN. MAY CAUSE
TRANSIENT IRRITATION. SKIN: EXPECTED TO BE LOW HAZARD FOR RECOMMENDED H
ANDLING. INGESTION: MAY BE HARMFUL IF SWALLOWED. CHRONIC: NONE SPECIFIED BY
MANUFACTURER.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:HOBART 24
CAGE:7A981
CAGE:7A981
============= Composition/Information on Ingredients =============
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: 60-100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 RESP. FRACT.
ACGIH TLV:10 MG/M3 TOTAL DUST
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:SODIUM SILICATE
CAS:1344-09-8
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:CELLULOSE (PAPER FIBER)
CAS:9004-34-6
RTECS #:FJ5691460
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 RESP. FRACT.
ACGIH TLV:10 MG/M3; 9293
Ingred Name:SILICA, AMORPHOUS, DIATOMACEOUS EARTH, CONTAINING LESS THAN
1% CRYSTALLINE SILICA
CAS:61790-53-2
RTECS #:HL8600000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:20 MPPCF
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:POTASSIUM SILICATE
CAS:1312-76-1
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV FOR WELDING FUMES IS 5 MG/M3
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: FUMES AND GASES CAN CAUSE EYES
AND UPPER RESPIRATORY SYSTEM IRRITATION, AND CENTRAL NERVOUS SYSTEM
EFFECTS. ARC RAYS CAN INJURE EYES AND BURN SKIN. ELECTRIC SHOCK CAN
KILL. NOISE CAN DAMAGE HEA RING. CHRONIC: NEUROLOGICAL DAMAGE, LUNG
FIBROSIS, PNEUMOCONIOSIS.
Effects of Overexposure:SHORT TERM EXPOSURE: NAUSEA, FEVER, DIZZINESS,
DRYNESS, IRRITATION OF EYES, NOSE AND THROAT, SKIN SENSITIVITY,
WATERY EYES, HEADACHE, BREATHING DIFFICULTY, FREQUENT COUGHING,
SHORTNESS OF BREATH.
Medical Cond Aggravated by Exposure:AGGRAVATION OF EXISTING RESPIRATORY
OR ALLERGIC CONDITIONS. HIGHER LEVEL OF LUNG RELATED PROBLEMS AMONG
SMOKERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE. IF BREATHING IS DIFFICULT,
GIVE OXYGEN. IF NOT BREATHING, GIVE CPR. IF NO DETECTABLE PULSE,
GIVE HEART MASSAGE. EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR AT
LEAST 1 5 MINUTES. SKIN: WASH WITH SOAP AND WATER. INGESTION: SEEK
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS. WELDING ARCS AND
SPARKS CAN IGNITE COMBUSTIBLE MATERIAL.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP ANY GRINDING DUST OR WASTE RESIDUE
AND PLACE IN APPROPIATE DISPOSAL CONTAINER. AVOID INHALATION AND
SKIN EXPOSURE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN DRY AREA. ELECTRODES EXPOSED
TO MOISTURE MAY EXPLODE VIOLENTLY IF USED. DRY MOIST RODS BY BAKING
AT 300F FOR TEN HOURS.
Other Precautions:TRAIN WELDER TO KEEP HIS HEAD OUT OF THE FUMES.
MONITOR AIR TO ENSURE ACCEPTABLE EXPOSURES. AVOID ELECTRICAL SHOCK
BY MAINTAINING DRY WORK AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FUME RESPIRATOR OR AIR SUPPLIED RESPIRATOR IN
CONFINED SPACES OR WHERE VENTILATION DOES NOT KEEP EXPOSURE BELOW
TLV.
Ventilation:LOCAL EXHAUST TO KEEP BELOW TLV.
Other Protective Equipment:SUBSTANTIAL DARK CLOTH, ARM PROTECTOR,
APRON, HAT AND SHOULDER PROTECTION. AIR SAMPLING TO DETERMINE
CORRECTIVE MEASURES
Work Hygienic Practices:WASH HANDS THOROUGHLY BEFORE EATING, SMOKING OR
USING SANITARY FACILITIES.
Supplemental Safety and Health
NONE.
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:INSOLUBLE.
Appearance and Odor:WELDING ROD 1/8 INCH DIAMETER BY 14 INCHES LONG.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:FUMES OF METALS AND METAL OXIDES FROM
ELECTRODE AND BASE METAL, CARBON MONOXIDE, CARBON DIOXIDE, OZONE,
NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT WITH YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF FUMES, FLUX OR WELD GRINDING RESIDUE FROM THE WORK AREA
OR FROM FILTERS IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:BRAEMAX AISI M-42
CAGE:93215
CAGE:93215
============= Composition/Information on Ingredients =============
Ingred Name:CHROMIUM (SARA III)
CAS:7440-47-3
RTECS #:GB4200000
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9293
Ingred Name:IRON ION (FE +2)
CAS:15438-31-0
RTECS #:NO6925000
OSHA PEL:1 MG/M3 (FE)
ACGIH TLV:1 MG/M3 (FE); 8990
Ingred Name:VANADIUM PENTOXIDE(SARA III)
CAS:1314-62-1
RTECS #:YW2460000
OSHA PEL:C,0.5 MG/M3
ACGIH TLV:0.05 MG/M3RDUST;9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:COBALT (SARA III)
CAS:7440-48-4
RTECS #:GF8750000
OSHA PEL:0.1 MG/M3;AS CO
ACGIH TLV:0.05 MG/M3;DUST 9293
======================= First Aid Measures =======================
First Aid:REMOVE TO FRESH AIR, CONSULT PHYSICIAN. FLUSH WITH WATER TO
REMOVE PARTICULATE. GET MEDICAL ATTENTION. BRUSHOFF EXCESS DUST.
WASH AREA WITH SOAP AND WATER. SEEK MEDICAL HELP IF LARGE
QUANTITIES OF MAT ERIAL HAVE BEEN INGESTED.
===================== Fire Fighting Measures =====================
Flash Point:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:USE GOOD HOUSEKEEPING PRACTICES TO
PREVENT ACCUMULATIONS OF DUST AND TO KEEP AIRBORNE DUST
CONNTRATIONS AT A MINIMUM..
============= Exposure Controls/Personal Protection =============
Respiratory Protection:PROVIDE NIOSH APPROVED RESPIRATORS, IF TLV.
Ventilation:GENERAL-RECOMMENDED. LOCAL-AS REQUIRED.
Other Protective Equipment:AS REQUIRED
Supplemental Safety and Health
MELTING PT = 2500F. ALSO CONTAINS: MANGANESE (OO9275000) 5.0% & NICKEL
(QR5950000) 1.0%. MSDS DATE: 20 NOV 85.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>5000F
Spec Gravity:8.2
Solubility in Water:INSOLUBLE
Appearance and Odor:VARIOUS SHAPES, SOLID ODORLESS METAL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTS WITH STRONG ACIDS TO GENERATE HYDROGEN GAS.
Hazardous Decomposition Products:METALLIC OXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW FEDERAL, STATE AND LOCAL REGULATIONS
REGARDING DISPOSAL.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:RE336361
CAGE:8X792
CAGE:75160
CAGE:8X792
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ETHER (CERCLA)
CAS:60-29-7
RTECS #:KI5775000
Fraction by Wt: 80.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:400 PPM
ACGIH TLV:400PPM/500STEL; 9596
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:BUTANE (TOTAL PERCENTAGE OF INGREDIENTS 2 AND 3: 10-20%)
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: 10-20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:800 PPM
ACGIH TLV:800 PPM; 9596
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 10-20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9596
Ingred Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: <10.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM/30000STEL;96
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATE, SOLVENT DEWAXED (MILD),
HEAVY PARAFFINIC/LUBRICATING OIL
CAS:64742-65-0
RTECS #:PY8038500
Fraction by Wt: <10.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 AS OIL MIST
ACGIH TLV:5 MG/M3 AS OIL MIST
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV FOR DIETHYL ETHER IS 400 PPM.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, RESPIRATORY TRACT.
ACUTE- EYES:MAY CAUSE IRRITATION/REDNESS. SKIN:IRRITATION &
DEFATTING WITH PROLONGED/REPEATED CONTACT. MAY CAUSE FROSTBITE.
INHALE:MAY CAUSE DIZZINESS, INTOXICATI ON, UNCONCIOUSNESS. MAY
CAUSE DEATH WITHOUT WARNING. ORAL:UNLIKELY TO OCCUR. CHRONIC-
UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, TEARING, REDNESS, DRYNESS OF SKIN
AND DEFATTING, DIZZINESS, HEADACHE, UNCONSCIOUSNESS, BLEACHING OF
SKIN, FROSTBITE, PAIN, DEATH
Medical Cond Aggravated by Exposure:PERSONS WITH CHRONIC RESPIRATORY OR
SKIN DISEASES MAY BE AT AN INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15
MINUTES, HOLDING EYELIDS OPEN. SKIN:FLUSH WITH WATER. TREAT FOR
FROSTBITE IF NEEDED. ORAL:GET MEDICAL ATTENTION IMMEDIATELY. NEVER
GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. PROPER TREATMENT
IS DEPENDENT ON CONDITION OF PATIENT AND AMOUNT INGESTED.
===================== Fire Fighting Measures =====================
Flash Point:-76F,-60C (GAS)
Lower Limits:1.9
Upper Limits:9.5
Extinguishing Media:USE WATER FOG/MIST, CARBON DIOXIDE (CO2), ALCOHOL
FOAM OR DRY CHEMICAL. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. RUN OFF TO SEWERS MAY CREATE
FIRE OR EXPLOSION.
Unusual Fire/Explosion Hazard:EXTREMELY FLAMMABLE. OVERHEATED AEROSOL
CANS COULD EXPLODE DUE TO INTERNAL PRESSURE BUILDUP. VAPORS MAY
TRAVEL TO AN IGNITION SOURCE AND FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. REMOVE LEAKING CONTAINER OUTDOOR/UNDER
THE HOOD. SOAK UP SPILL WITH NON-FLAMMABLE ABSORBENT SUCH AS SAND,
VERMICULITE. PLACE I N CONTAINER. PREVENT LIQUID FROM ENTERING
SEWERS.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, WELL VENTILATED AREA
AWAY FROM SPARKS, FLAME, OTHER SOURCES OF IGNITION & INCOMPATIBLE
MATERIALS. DO NOT STORE ABOVE 120F.
Other Precautions:AVOID BREATHING VAPOR/MIST. AVOID CONTACT WITH EYES/
SKIN. FOR INDUSTRIAL USE ONLY. KEEP OUT OF REACH OF CHILDREN. DO
NOT SPRAY IN DIRECTION OF BODY. READ LABEL CAREFULLY. EMPTY
CONTAINER RETAINS RESI DUE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV IS EXCEEDED OR FOR SYMPTOMS OF OVER
EXPOSURE, WEAR NIOSH-APPROVED ORGANIC VAPOR RESPIRATOR OR
AIR-PURIFYING RESPIRATOR. IN EMERGENCY, WEAR A NIOSH-APPROVED
POSITIVE-PRESSURE SELF- CONTAINED BRE ATHING APPARATUS.
Ventilation:MECHANICAL (GENERAL AND/OR LOCAL EXHAUST, EXPLOSION-PROOF)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:SAFETY SHOWER AND EYE WASH FOUNTAIN SHOULD
BE LOCATED NEARBY. WEAR APPROPRIATE PROTECTIVE CLOTHING FOR RISK OF
EXPOSURE.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
THIS ITEM IS FOR USE WITH TRACTORS ONLY. NOT FOR AUTOMOBILE USE.
================== Physical/Chemical Properties ==================
HCC:V3
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:94.1F,34.5C
Vapor Density:>1.5
Spec Gravity:0.721
Evaporation Rate & Reference:>1 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLUE LIQUID - SLIGHT ETHEREAL ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:SPARKS, HOT SURFACES, FLAME. TENDS TO
PRODUCE EXPLOSIVE PEROXIDE ON LONG STANDING IN PRESENCE OF AIR &
LIGHT.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. DO NOT PUNCTURE, MUTILATE OR INCINERATE
CONTAINERS. AVOID CONTAMINATION OF ANY GROUND WATER.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:D.E.H. 24 EPOXY CURING AGENT
CAGE:5D028
CAGE:96717
CAGE:5D028
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENEAMINES
Fraction by Wt: 99.0%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 1.0%
===================== Hazards Identification =====================
Effects of Overexposure:EYE: POSSIBLE BURN. SKIN: POSSIBLE BURN,
SENSITIZER. INH: BAD ODOR & IRRIT RESPIR TRACT, SENSITIZE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/ WATER FOR 15 MIN, SEE DR. PROMPTLY. SKIN:
FLUSH W/ WATER, IMMED REMOVE CONTAMINATED CLOTHES, WASH BEFORE
REUSE. INH: REMOVE TO FRESH AIR, KEEP WARM & QUIET, SEE DR.
PROMPTLY. INGEST: DO NOT INDUCE VOMIT, FORCE MILK OR WATER,SEE
DR.!
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:265F,129C
Extinguishing Media:WATER FOG, CO*2, DRY CHEMICAL, ALCOHOL FOAM, FOAM
(LG AMT)
Fire Fighting Procedures:FULL PROTECTIVE CLOTHING & SELF-CONTAINED
BREATHING EQUIP.
================== Accidental Release Measures ==================
Spill Release Procedures:WASH WITH WATER. CONTACT DOW, TEXAS DIV.,
(713) 238-2011 FOR ADDITIONAL INFORMATION. IN CASE OF EMERGENCY
SITUATION, GET WATER ON THE SPILL & FLUSH CONTACT AREAS.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH EYES AND SKIN.
DEH-24 SHOULD NOT CONTACT COPPER, BRASS, BRONZE OR OTHER
COPPER-BEARING ALLOYS.
Other Precautions:STAINLESS STEEL, ALUMINUM & STEEL ARE SUITABLE
MATERIALS OF CONSTRUCTION; GROUND ALL EQUIP; IF WATER &/OR CO*2
PICK-UP IS CRITICAL TO THE END-USE, PADDING THE TANK WITH DRY
NITROGEN IS RECOMM.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ALL PURPOSE CANISTER FOR GAS MASK - APPROPRIATE,
APPROVED TYPE
Ventilation:NO SPECIAL EQUIP IS NEEDED IF TEMPERATURE IS AMBIENT.
Other Protective Equipment:HARD HAT, RUBBER SUIT, RUBBER BOOTS (CHEM.
Supplemental Safety and Health
ONE OF THREE COMPONENTS USED IN THE E312 EPOXY KITS. SPECIFIC
GRAVITY:0.9730-0.9810 AT 25/25C. FORMULA:
NH*2-CH*2-CH*2-NH-CH*2CH*2NHCH*2CH*2NH*2. LD50, FOR RATS, IS 1400
MG/KG.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:260 TO 290C
Solubility in Water:COMPLETE
Appearance and Odor:<50 APHA AMMONICAL LIQUID
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACID, CHLORINATED COMPOUNDS
Stability Condition to Avoid:STABLE - VAPORS REACT W/ CO*2 & WATER.
VAPOR PRODUCES FOG.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FED., STATE, & LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:PRESTO BLACK PC-6
CAGE:0HLC1
CAGE:51243
CAGE:0HLC1
============= Composition/Information on Ingredients =============
Ingred Name:SELENIOUS ACID (SARA III)
CAS:7783-00-8
RTECS #:VS7175000
Fraction by Wt: <4.0%
OSHA PEL:0.2 MG SE/M3
ACGIH TLV:0.2 MG SE/M3; 9192
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:CUPRIC NITRATE: CU(NO*3)*2
Fraction by Wt: <2.0%
===================== Hazards Identification =====================
Effects of Overexposure:GASTROINTESTINAL DISTURBANCES,GARLIC ODOR OF
BREATH,DIZZINESS,FATIGABILITY,DIFFACULTY BREATHING.
======================= First Aid Measures =======================
First Aid:SKIN OR EYE CONTACT:RINSE AFFECTED AREA IMMEDIATELY AND
THOROUGHLY.SEEK MEDICAL ATTENTION FOR EYE CONTACT.
INGESTION:GASTRIC LAVAGE,SALINE CATHARSIS,ADMINISTER OXYGEN IF
BREATHING DIFFICULT.GIVE DIURE TIC,VITAMINS C & B
COMPLEX,METHIONINE SUPPLEMENTS.
================== Accidental Release Measures ==================
Spill Release Procedures:DILUTE WITH WATER OR NEUTRALIZE WITH SODIUM
BICARBONATE & ABSORB ON SAWDUST OR EQUIVALENT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN ACID RESISTANT
CONTAINERS.AVOID STORING OR TRANSPORTING WITH CYANIDES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NECESSARY WHEN USED ACCORDING TO
INSTRUCTIONS.
Ventilation:LOCAL EXHAUST IS RECOMMENDED.
Other Protective Equipment:RUBBER OR PLASTIC APRON.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:214F
Vapor Pres:UNK
Spec Gravity:1.055
Evaporation Rate & Reference:UNK
Solubility in Water:COMPLETE
Appearance and Odor:ODORLESS BLUE SOLUTION
Percent Volatiles by Volume:0.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CYANIDES,ORGANIC COMPOUNDS(E.G.OILS,SOLVENTS)
Hazardous Decomposition Products:NO DATA
==================== Disposal Considerations ====================
Waste Disposal Methods:ADD 1 OZ,H*2,SO*4 PER GALLON;ADD STEEL WOOL OR
IRON FILINGS(2-4 OZ/GAL):ALLOW TO REACT COMPLETELY;ADJUST PH TO
8.0;FILTER LIQUID TO DRAIN.SOLIDS TO LANDFILL
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:DULUX ALKYD ENAMEL TINTS, 93-082
CAGE:B0589
CAGE:B0589
CAGE:18873
============= Composition/Information on Ingredients =============
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 2%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:AROMATIC HYDROCARBON. VP: 10 @ 20C.
CAS:64742-95-6
OSHA PEL:25 PPM (MFR)
ACGIH TLV:25 PPM (MFR)
Ingred Name:LEAD SULFOCHROME (LEAD CHROMATE).
CAS:1344-37-2
Fraction by Wt: 15%
OSHA PEL:0.5 MG(CR)/M3
ACGIH TLV:0.05 MG(PB)/M3
Ingred Name:ALKYD RESIN.
Ingred Name:MOLYBDATE ORANGE (LEAD CHROMATE-MOLYBDATE).
CAS:12656-85-8
RTECS #:QA4660000
Fraction by Wt: 7%
OSHA PEL:5 MG(MO)/M3
ACGIH TLV:5 MG(MO)/M3
Ingred Name:VM&P NAPHTHA.
CAS:64742-89-8
Other REC Limits:100 PPM (MFR)
OSHA PEL:300PPM;400 STEL(MFR)
ACGIH TLV:300 PPM (MFR)
Ingred Name:NAPHTHA, MEDIUM ALIPHATIC (MEDIUM MINERAL SPIRITS).
CAS:64742-88-7
Other REC Limits:100 PPM (MFR)
Ingred Name:NAPHTHENIC ACID, LEAD SALT (LEAD DRIER).
CAS:61790-14-5
RTECS #:QK9150000
Fraction by Wt: 1%
OSHA PEL:SEE 1910.1025
ACGIH TLV:0.15 MG(PB)/M3
Ingred Name:AROMATIC HYDROCARBON. VP: 10 @ 20C.
CAS:64742-94-5
Other REC Limits:100 PPM (MFR)
Ingred Name:RESP PROT: OR IF THIS PROD IS USED W/AN ISOCYANATE ADDITIVE
(DULUX PLUS), WEAR A NIOSH/MSHA APPRVD POS-PRESS, (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: SUPPLIED-AIR RESP (TC-19C). REFER TO THE ADDITIVE
LABEL & MSDS FOR FURTHER INFO. IN ALL CASES, FOLLOW (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: THE RESPIRATOR MFR'S DIRECTIONS FOR RESPIRATOR USE;
DO NOT PERMIT ANYONE W/O PROTECTION IN THE PAINTING AREA.
RTECS #:9999999ZZ
Ingred Name:SUPP DATA: LAB STUDIES W/RATS HAVE SHOWN THAT PETRO DISTILL
CAUSE KIDNEY DMG & KIDNEY/LIVER TUMORS. THESE EFTS (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: WERE NOT SEEN IN SIMILAR STUDIES W/GUINEA PIGS,
DOGS, MONKEYS. SEVERAL STUDIES EVALUATING PETRO WORKERS (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: HAVE NOT SHOWN SIGNIFICANT INCREASES OF KIDNEY DMG
NOR KIDNEY/LIVER TUMORS. LEAD CHROMATE/LEAD CHROMATE (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: MOLYBDATE: OVEREXP TO LEAD MAY CAUSE ADVERSE EFTS
TO THE BLOOD FORMING, NERVS, URINARY, REPRO SYS INCL (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: EMBRYOTOXIC EFTS. SYMPS MAY INCL LOSS OF APPETITE,
ANEMIA, DISTURB OF SLEEP & FATG. SEE OSHA LEAD STD (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17: 29CFR1910.1025 FOR EXPOS LONGER THAN 8HRS. THE OSHA
EXPOS LIM IS REDUCED BY THIS FORMULA: LIM(IN UG/M3) (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: =400/HRS WORKED IN THE DAY. LEAD DRIER: OVEREXP TO
LEAD MAY CAUSE ADVERSE EFTS TO THE BLOOD FORMING, (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19: NERVS, URINARY, REPRO SYS INCLUDING EMBRYOTOXIC
EFTS. SYMPS MAY INCL LOSS OF APPETITE, ANEMIA, DISTURB (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20: OF SLEEP & FATG. SEE OSHA LEAD STD 29CFR1910.1025.
FOR EXPOS LONGER THAN 8HRS THE OSHA EXPOS LIMIT IS (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21: REDUCED BY THIS FORMULA: LIMIT(IN UG/M3)=400/HRS
WORKED IN THE DAY. CAN BE ABSORBED THRU THE SKIN IN (ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22: HARMFUL AMTS. AROMATIC HYDROCARBON: RECURRENT
OVEREXP MAY RSLT IN LIVER/KIDNEY INJURY. HAS BEEN TOXIC (ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23: TO THE FETUS IN LAB ANIMALS AT DOSES THAT ARE TOXIC
TO THE MOTHER.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:GENL EFTS: INGEST: GI DISTRESS. INHAL:
MAY CAUSE NOSE/THROAT IRRIT. RPTD/PRLNG OVEREXP TO SOLV MAY LEAD TO
PERM BRAIN/NERVS SYS DMG. EYE WATERING, HDCH, NAUS, DIZZ & LOSS OF
COORD ARE SIGNS THAT SOLV LEVELS ARE TOO HIGH. PRODS MAY BE USED
IN COMBINATION W/A HARDENER WHICH CONTAINS AN ISOCYANATE. (SEE EFTS
OF OVEREXP)
Explanation of Carcinogenicity:LEAD CHROMATE & LEAD CHROMATE MOLYBDATE:
IARC, GROUP 1.
Effects of Overexposure:HLTH HAZ: EXPOS TO ISOCYANATES MAY CAUSE
ASTHMA-LIKE RXNS W/SHORTNESS OF BREATH, WHEEZING, COUGH OR LUNG
SENSIT. THIS EFT MAY BE DELAYED FOR SEVERAL HRS AFTER EXPOS.
INDIVIDUALS W/LUNG/BRTHG PROB/PRIO R RXN TO ISOCYANATES MUST NOT BE
EXPOSED TO VAPS/SPRAY MIST OF PROD. EYE: MAY CAUSE IRRIT/BURNING.
SKIN: (SEE SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMEDIATELY AND HAVE THE NAMES OF INGREDIENTS
AVAILABLE. INHAL: IF BY VAPOR OR SPRAY MIST, REMOVE TO FRESH AIR.
IF BREATHING DIFFICULTY PERSISTS, OR OCCURS LATER, CONSULT MD. EYE:
IMME DIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES;
CALL MD. SKIN: WASH WITH SOAP AND WATER. IF IRRITATION OCCURS,
CONTACT MD.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:-73F,-58C
Lower Limits:0.8%
Upper Limits:11.5%
Extinguishing Media:WATER SPRAY, FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA AND FULL
PROTECTIVE EQUIPMENT. WATER FROM FOG NOZZLES MAY BE USED TO COOL
CLOSED CONTAINERS TO PREVENT PRESSURE BUILD UP.
Unusual Fire/Explosion Hazard:WHEN HEATED ABOVE THE FLASH POINT, EMITS
FLAMM VAPS WHICH, WHEN MIXED W/AIR, CAN BURN/BE EXPLO. FINE
MISTS/SPRAYS MAY BE FLAMM AT TEMPS BELOW THE FLASH POINT.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE SOURCES OF IGNITION.
PREVENT SKIN CONTACT AND BREATHING OF VAPOR. WEAR A PROPERLY FITTED
VAPOR/PARTICULATE RESPIRATOR (NIOSH/MSHA TC-23C). CONFINE AND
REMOVE WITH INERT ABSORBEN T.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:OBSERVE LABEL PREC. KEEP AWAY FROM
HEAT, SPARKS AND FLAME. CLOSE CONTAINER AFTER EACH USE. GROUND
CONTAINERS WHEN POURING. DO NOT STORE ABOVE 120F.
Other Precautions:DO NOT SAND, FLAME CUT, BRAZE OR WELD DRY COATING
WITHOUT A NIOSH/MSHA APPROVED RESPIRATOR OR APPROPRIATE
VENTILATION. DO NOT BREATHE VAPORS OR MISTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR PROPERLY FITTED NIOSH/MSHA APPRVD PAINT
SPRAY RESP (TC-23C) DURING APPLICATN & UNTIL ALL VAP/SPRAY MISTS
ARE EXHSTD. IN CONFINED SPACES/IN SITUATIONS WHERE CONTINUOUS SPRAY
OPS ARE TYPICAL/IF PRO PER RESP FIT IS NOT POSS (SEE INGRED 10)
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME AND PATTERN TO
KEEP CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Other Protective Equipment:COVERALLS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING OR SMOKING.
Supplemental Safety and Health
% VOLAT: 57.6-70.9. EFTS OF OVEREXP: RPTD/PRLNG LIQ CNTCT MAY CAUSE
IRRIT W/DISCOMFORT & DERM. SPECIFIC EFTS: XYLENE: HIGH CONC HAVE
CAUSED EMBRYOTOXIC EFTS IN LAB ANIMALS. RECURRENT OVEREXP MAY RSLT
IN LIVER/KIDNEY INJURY. CAN BE ABSORBEDTHRU SKIN IN HARMFUL AMTS.
VM&P NAPHTHA/MEDIUM MINERAL SPIRITS: (SEE INGRED 13)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>172F,>78C
Vapor Pres:SEE INGRED
Vapor Density:> AIR
Spec Gravity:0.9-1.12
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:MISCIBLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CO, CO*2, SMOKE, OXIDES OF HEAVY
METALS REPORTED IN INGREDIENTS SECTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. INCINERATE ABSORBED MATERIAL IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REQUIREMENTS. DO NOT INCINERATE IN CLOSED
CONTAINERS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:FERRITIN RIA KIT (125I)
CAGE:5R665
CAGE:5R665
============= Composition/Information on Ingredients =============
Ingred Name:IODINE-125 - RADIOACTIVE TRACER ELEMENT - <2.5 UCI/VIAL
HALF LIFE - 60 DAYS
Ingred Name:SODIUM AZIDE (SARA III)
CAS:26628-22-8
RTECS #:VY8050000
OSHA PEL:S, C 0.1 PPM(HN3)
ACGIH TLV:C 0.11 PPM; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HUMAN SERUM
===================== Hazards Identification =====================
Effects of Overexposure:HANDLE AS IF CAPABLE OF TRANSMITTING INFECTION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES: SKIN: REMOVE CONTAMINATED CLOTHING & WASH EXPOSED
THOROUGHLY WITH SOAP & WATER. INGESTION: FLUSH WITH WATER, INSURING
RINSE ISN'T SWALL OWED. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:NON-FLAMMABLE
Unusual Fire/Explosion Hazard:IF DRAIN DISPOSED FLUSH WITH A LARGE
VOLUME OF WATER TO PREVENT AZIDE BUILD-UP.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP SPILLS W/ABSORBENT PAPER. THEN CLEAN
SPILL AREA THOROUGHLY WITH 5% SODIUM HYCHLORITE (CHLOROX) SOLUTION.
DISCARD ALL MATERIALS USED TO WIPE UP SPILLIN BIOHAZARDOUS WASTE
FOR PROPER DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T PIPET BY MOUTH. DON'T EAT, DRINK
OR SMOKE IN THE LABORATORY. WEAR DISPOSABLE RUBBER GLOV WHILE
HANDLING THESE COMPONENTS.
Other Precautions:STORE AT 2 TO 8C. STORE TRACER AT ROOM TEMP (2-27C).
RESEAL UNUSED TUBES IN ORIGINAL CONTAINERS. EMPTY CONTAINERS SHOULD
BE TOCLAVED FOR AT LEAST 1 HR AT 121.5C BEFORE DISCARDING.
============= Exposure Controls/Personal Protection =============
Supplemental Safety and Health
MSDS DATE: 10/22/86. KIT CONTAINS: FERRRTIN TRACER SOLUTION, FERRITIN
SERUM STANDARDS A-G, GARGG, PRECIPITATING SOLUTION, RRITIN
ANTISERUM.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
LEAD & COPPER PLUMBING
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARD USED TUBES IN RADIOACTIVE WASTE. ALL
RADIOACTIVE MATERIALS MUST BE DISPOSED OF IN ACCORDANCE WITH
PREVAILING REGULATIONS AND GUIDELINED OF THE AGENCIES HOLDING
JURISDICTION OVER THE LABORATORY .
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:WOOD BLEACH-SOLUTION A, WB-19
Kit Part:Y
CAGE:IO259
CAGE:25451
CAGE:IO259
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE (CERCLA). VP: 1.53 @ 15.6C
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: <5%
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: BALANCE
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: NONE RECOGNIZED.
INGESTION: MAY CAUSE BURNING IN MOUTH AND ESOPHAGUS, NAUSEA,
VOMITING, ABDOMINAL PAIN, DIARRHEA, OCCASIONALLY WITH BLOOD AND
PERFORATION OF INTESTINAL TRACT POSSIBL E. SKIN: CAUSES BURNS TO
SKIN AND EYES.CHRONIC: NONE RECOGNIZED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . INGEST: CALL YOUR HOSPITAL EMERGENCY ROOM, POISON CONTROL
CENTER OR PHYSICIAN IMMEDIATELY FOR INSTRUCTIONS. EYE: FLUSH WITH L
ARGE QUANTITIES OF WATER FOR AT LEAST 15 MINUTES AND SEEK IMMEDIATE
MEDICAL ATTENTION. SKIN: WASH WITH SOAP AND LARGE QUANTITIES OF
WATER & SEEK MEDICAL ATTENTION IF IRRITATION FROM CONTACT PERSISTS.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NONE. MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH LARGE SPILLS OF MATERIAL INTO SUITABLE
RETAINING AREA OR CONTAINERS WITH LARGE QUANTITIES OF WATER. SMALL
SPILLS CAN BE ABSORBED BY APPROPRATE INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE NEAR FLAMES OR AT
ELEVATED TEMPERATURES.
Other Precautions:READ CAREFULLY ALL CAUTIONS AND DIRECTIONS ON PRODUCT
LABEL BEFORE USE. SINCE EMPTY CONTAINER RETAINS RESIDUE, FOLLOW ALL
LABEL WARNING EVEN AFTER CONTAINER IS EMPTY. DISPOSE OF EMPTY
CONTAINER ACCCOR DING TO LOCAL REGULATIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USUALLY NONE REQUIRED. NIOSH APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:USUALLY NONE REQUIRED.
Other Protective Equipment:ANSI APPRVD EMER EYE WASH & DELUGE SHOWER .
VARYING APPLICATIONS METHODS CAN DICTATE USE OF ADDITIONAL (SUPDAT)
Work Hygienic Practices:BEFORE REUSE, THOROUGHLY CLEAN ANY CLOTHING OR
PROTECTIVE EQUIPMENT WHICH HAS BEEN CONTAMINATED BY PRIOR USE.
Supplemental Safety and Health
OTHER PROT EQUIP: PROTECTIVE, SUCH AS IMPERMEABLE APRONS, ETC. EYE
PROT: AND FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:290F,143C
Vapor Pres:SEE ING 1
Vapor Density:HVR/AIR
Spec Gravity:1.05
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:76
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, CHLORINATED SOLVENTS, ALUMINUM, TIN AND ZINC.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE RECOGNIZED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH APPLICABLE LOCAL,
STATE AND FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:PWC218 POLYURETHANE AEROSOL COLOR
CAGE:58977
CAGE:58977
============= Composition/Information on Ingredients =============
Ingred Name:SS 31 N-BUTYL ACETATE
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 5%
OSHA PEL:150PPM
ACGIH TLV:150PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SS 12XYLENE
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 13%
OSHA PEL:100PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SS01 MINERAL SPIRITS
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: <5%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:SS41ACETONE
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 35%
OSHA PEL:750 PPM
ACGIH TLV:750 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PR01APROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 15%
OSHA PEL:1000PPM
ACGIH TLV:1000PPM
Ingred Name:PR01BISOBUTANE
CAS:75-28-5
RTECS #:TI4300000
Fraction by Wt: <5%
Other REC Limits:<-ESTIMATE
OSHA PEL:800 PPM
ACGIH TLV:8000 PPM
Ingred Name:PR01C NORMALBUTANE
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: 10%
OSHA PEL:6000 PPM
ACGIH TLV:700 OOM
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE TOXICOLOGICAL
Routes of Entry: Inhalation:UNKNOWN Skin:UNKNOWN Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION:ANESTHETIC. IRRITATION OF
RESPIRATORY TRACT OR NERVOUS SYSTEM, DEPRESSION-CHARACTERIZED BY
HEADACHE, DIZZINESS, NAUSEA OR POSSIBLE UNCONSCIOUSNESS. SKIN
CONTACT:PRIMARY IRRITATION. MAY CAUS E DERMATITUS. PROLONGED OR
REPEATED CONTACT MAY CAUSE DERMATITIS-EXERCISE DUE CARE. EYE (EFTS
OF OVEREXP)
Effects of Overexposure:HLTH HAZ: MAY CAUSE NAUSEA AND DIZZINESS. SKIN:
CONTACT:PRIMARY IRRITATION. SKIN ABSORPTION:MAY CAUSE IRRITATION OR
BURNING SENSATION. INGESTION:NOT APPLICABLE. EYES: PRIMARY
IRRITATION. INGESTION N/A .
======================= First Aid Measures =======================
First Aid:VAPORS: REMOVE FROM EZPOSURE AND RESTORE BREATHING, SEEK
MEDICAL ATTENTION. SPLASH; 9SKIN0 WASH EFFECTED AREA REMOVE
OCNTAMINATD CLOTHING, SEE PHYCIAN IF IRRITATION PRRSISTS. SPLASH
(EYES) FLUSH IMMID IEATLEY WITH WATER FOR 15 MINUTES AND TAKE TO A
PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:=-26.C, -14.8F
-26C
Lower Limits:0.7%
Upper Limits:12.8%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER SPRAY MAY BE INEFT, BUT WATER SPRAY MAY BE USED TO COOL
CNTNRS EXPOS TO HEAT/FIRE TO PVNT PRESS BUILD UP.
Unusual Fire/Explosion Hazard:CLSD CNTNRS MAY EXPLODE DUE TO BUILD UP
OF PRESS FROM EXTREME HEAT/FIRE. AEROSOL SPRAY IS EXTREMELY FLAMM.
SENSITIVITY TO IMPACT:DO NOT PUNCTURE. SENSITIVIEY TO STATIC
DISCHARGE MOSTLY VAPOR.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION; SPARKS,
FLAMES, STATIC ELECTRICITY & ELECTRICAL. VENTILATE AREA & SOAK UP
W/INERT ABSORBENT USING NON-SPARKING TYPE TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. DO NOT STORE
OR USE NEAR HEAT, SPARKS OR FLAME.
Other Precautions:DO NOT GET IN EYES. DONOT BREATH VAPORS AVOID SKIN
CONTACT. DO NOT TAKE INTERNALLY. SMOKING WHILE USING THIS PRODUCT
MUST BE STRICTLY PROHIBITED. IN ADDITION TO ALL OTHER HAZARDS &
PRECAUTIONS - DUSTFROM SANDING DRY PAINT FILMS SHOULD BE TREATED
AS A NUISANCE DUST W/TLV OF 10 MG/M3.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:OUTDOORS:MFR RECOMMENDS A NIOSH APPROVED
PARTICULATE FILTER TO REMOVE ANY AIRBORNE OVERSPRAY. IN RESTRICTED
AREAS W/POOR VENTILATION & CLOSE TO TLV, A NIOSH APPROVED
RESPIRATOR W/ORGANIC VAPOR CARTRID GE IS RECOMMENDED.
Ventilation:ALL APPLICATION AREAS SHOULD BE ADEQUATELY VENTILATED IN
ORDER TO KEEP INGREDIENTS BELOW THEIR EXPOSURE LIMITS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . IMPERVIOUS APRON TO PREVENT SKIN CONT IS
REC.
Work Hygienic Practices:AVOID PROLONGED OR REPEATED CONTACT. WASH
CONTAMINATED CLOTHING PRIOR TO RE-USE. DO NOT BREATHE VAPORS
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:=-23.3C, -10.F
B.P. Text:-10F
Vapor Density:HVR/AIR
Spec Gravity:0.7 (H*2O=1)
VOC Pounds/Gallon:48
VOC Grams/Liter:3.59
Evaporation Rate & Reference:FASTER THAN N-BUAC
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OPAQUE LIQUID; SOLVENT BASED ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:CO, CO*2, HCL & POSSIBLY TRACES OF
PHOSGENE.
=================== Toxicological Information===================
Toxicological Information:SS31N-BUTYL ACETATE LC50: 13100 MG/KG RAT
ORAL; LC50 2000 PPM/4 HR RAT INHA. SS12 XYLENE; LD50; 4300 MG/KG
RET ORAL; LC50 6700PPM/4 HR RAT INHA. SS41ACETONE; LD50: 9750MG/KG
RAT ORAL. PR10B ISOBUATNE LC50: 520000PPM/2 HR MOUSE EXP.
PR01CNORMAL BUTANE LC50: 6580MG/L 4 HR RAT INHA.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.
=================== MSDS Transport Information ===================
Transport Information:FLAMABILITY-T.D.G.R. CLASS: CONDUER COMODITY
ORM-D.
===================== Regulatory Information =====================
SARA Title III Information:SS12XYLENE
| 1 |
gloves_mandatory
|
=======================================================
NIIN: 01-349-6726
Product ID: WESCOR AEROFIX ADDITIVE 135 ML
Cage: 57699
Proprietary Ind: Y
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 57699
=======================================================
Contractor Summary
=======================================================
Cage: 57699
=======================================================
Item Description Information
=======================================================
Item Name: METHANOL SOLUTION
Unit of Issue: BT
Quantitative Expression: 00000000135ML
UI Container Qty: 1
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: YES
OSHA: NO
Effects of Exposure: SKIN: REPEATED EXPOSURE MAY RESULT IN ABSORPTION OF
HARMFUL QUANTITIES. INGESTION: MODERATE ORAL TOXICITY. MAY CAUSE CNS EFFECTS,
KIDNEY FAILURE. ESTIMATED AVERAGE LETHAL DOSE IS 100 ML. INHALATION: M AY
CAUSE IRRITATION. EYES: SLIGHT TEMPORARY IRRITATION.
Explanation Of Carcinogenicity: SEE INGREDIENTS
Signs And Symptions Of Overexposure: IRRITATION & METABOLIC ACIDOSIS.
First Aid: SKIN: WASH W/WATER. INGESTION: IMMEDIATELY INDUCE VOMITING AS
DIRECTED BY MEDICAL PERSONNEL. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON. INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH W/PLENT Y OF WATER FOR 5
MINS. OBTAIN MEDICAL ATTENTION IN ALL CASES. NOTE TO PHYSICIAN: EARLY
ADMINISTRATION OF ETHANOL MAY COUNTER TOXIC EFFECTS OF ETHYLENE GLYCOL. (SEE
SUPP)
=======================================================
Handling and Disposal
=======================================================
MATERIAL & COLLECT FOR DISPOSAL. WASH SITE W/SOAP/MILD DETERGENT &
WATER AFTER CLEANUP.
Waste Disposal Methods: BURN IN AN APPROVED INCINERATOR IAW/FEDERAL, STATE
& LOCAL REGULATIONS.
Handling And Storage Precautions: STORE BETWEEN 64.4-87.8F. AVOID ACIDS &
STRONG OXIDIZING AGENTS. KEEP IN TIGHTLY CLOSED CONTAINER STORED IN A COOL,
DRY, VENTILATED AREA.
Other Precautions: PROTECT FROM PHYSICAL DAMAGE. KEEP OUT OF REACH OF CHILDREN.
AVOID BREATHING VAPORS, CONTACT W/SKIN & EYES.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: 246F
Lower Limits: 3.2
Upper Limits: 15.3
Extinguishing Media: WATER FOG, DRY CHEMCIAL, ALCOHOL FOAM, CO2.
Fire Fighting Procedures: WEAR FULL PROTECTIVE CLOTHING & NIOSH APPROVED
SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard: SLIGHT-MODERATE FIRE HAZARD WHEN EXPOSED TO HIGH
HEAT/FLAME. VAPOR-AIR MIXTURES ARE EXPLOSIVE >246F. WILL IGNITE IN AIR AT
775.4F.
=======================================================
Control Measures
=======================================================
Respiratory Protection: WEAR A SELF CONTAINED BREATHING APPARATUS IF >TLV.
Ventilation: MECHANICAL (GENERAL ROOM VENT)
Other Protective Equipment: EYE WASH FACILITY, SAFETY SHOWER
Supplemental Safety and Health: FIRST AID CONT'D: HEMODIALYSIS/PERITONEAL
DIALYSIS HAVE BEEN OF BENEFIT.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 379.4F
M.P/F.P Text: 8.6F
Vapor Pres: 0.1
Vapor Density: 2
Solubility in Water: MISCIBLE
Appearance and Odor: PALE BLUE VISCOUS LIQUID W/FAINT TO NO ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: EXTREME HEAT/FLAME.
Materials To Avoid: STRONG OXIDIZING AGENTS & ACIDS.
Hazardous Decomposition Products: CO, CO2, NITROGEN OXIDES & FORMALDEHYDE.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: WESCOR AEROFIX ADDITIVE 135 ML
Cage: 57699
Company Name: WESCOR INC
Street: 459 S MAIN ST
Zipcode: 84321-5207
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: SKIN: REPEATED EXPOSURE MAY RESULT IN ABSORPTION OF
HARMFUL QUANTITIES. INGESTION: MODERATE ORAL TOXICITY. MAY CAUSE CNS EFFECTS,
KIDNEY FAILURE. ESTIMATED AVERAGE LETHAL DOSE IS 100 ML. INHALATION: M AY
CAUSE IRRITATION. EYES: SLIGHT TEMPORARY IRRITATION.
IRRITATION & METABOLIC ACIDOSIS.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:894 2K HARDENER (OLD FORMULATION)
CAGE:INMON
CAGE:75503
CAGE:INMON
============= Composition/Information on Ingredients =============
Ingred Name:HEXYL ACETATE (LEL=1.7, VAPOR PRESSURE=8.5 MMHG (MFR))
CAS:88230-35-7
Fraction by Wt: 50%
Other REC Limits:TLV:50 PPM,300MG/CUM
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: <5%
Other REC Limits:N/K
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:AROMATIC HYDROCARBON 100 (LEL=0.9, VAPOR PRESSURE=10.0
(MFR))
CAS:64742-95-6
Fraction by Wt: <5%
Other REC Limits:TLV:50 PPM
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ALIPHATIC POLYISOCYANATE
CAS:3779-63-3
Fraction by Wt: 45.23%
Other REC Limits:TLV=0.02
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CHRONIC:MAY CAUSE ALLERGIC REACTION
INVOLVING RESPIRATORY SYSTEM & SKIN;EFFECTS MAY BE
PERMANENT.INDIVIDUALS WITH LUNG OR BREATHING PROBLEMS OR PRIOR
REACTION TO ISOCYANATES MUST NOT BE EXPOSED TO VAP OR OR SPRAY
MIST.
Explanation of Carcinogenicity:N/A
Effects of Overexposure:ACUTE:INHALATION:ANESTHETIC.IRRITATION OF
RESPIRATORY TRACT OR ACUTE NERVOUS SYSTEM DEPRESSION CHARACTERIZED
BY THE FOLLOWING PROGRESSIVE STEPS:HEADACHE, DIZZINESS, STAGGERING
GAIT, CONFUSION, UNCONSC IOUSNESS OR COMA. SKIN OR EYE
CONTACT:PRIMARY IRRITATION.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH LUNG OR BREATHING
PROBLEMS OR PRIOR REACTION TO ISOCYANATES.
======================= First Aid Measures =======================
First Aid:INGESTION:CALL MD IMMEDIATELY . VAPOR INHALATION:RESTORE
BREATHING. REMOVE TO FRESH AIR. KEEP WARM & QUIET. NOTIFY
PHYSICIAN. EYE CONTACT:FLUSH IMMEDIATELY WITH COPIOUS AMOUNTS OF
RUNNING WATER FOR AT LEAST 15 MINUTES. TAKE TO PHYSICIAN FOR
DEFINITIVE MEDICAL TREATMENT. SKIN CONTACT:CLEAN & WASH AFFECTED
AREA WITH WATER. CONSULT PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:85 +/- 5F (29C)
Lower Limits:N/K
Upper Limits:N/K
Extinguishing Media:FOAM, CARBON DIOXIDE, CHEMICAL POWDER
Fire Fighting Procedures:USE NIOSH/MSHA APVD SCBA & FULL PROT EQPT.H*2O
SPRAY MAY BE INEFFECT.IF H*2O USED,FOG NOZZLE PREFER.USE H*2O TO
COOL CLOSED CNTNR TO PVNT PRESS(SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP CNTNR TIGHT CLOSE.AVOID HEAT,OPEN
FLAMES,STATIC ELEC,ELEC EQPT & SPARK.CLOSE CNTNR MAY EXPLD WHEN
EXPOS TO EXTM HEAT.APPL TO HOT SURF REQ SPECIAL(SUP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE ALL POSSIBLE SOURCES OF
IGNITION. AVOID PROLONGED BREATHING OF VAPORS. CONFINE SPILL WITH
INERT ABSORBENT AND CLEAN UP WITH SPARK-PROOF TOOLS.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE OVER 120F(49C). WHEN
STORING LARGE QTY,STORE IN BUILDING DESIGNED & PROTECT AGAINST
FLAMMABLE LIQ. USE STATIC LINES WHEN MIX & XFR MATL.
Other Precautions:FOR INDUSTRIAL USE ONLY. DO NOT TAKE INTERNALLY. IF
INGESTED, DO NOT INDUCE VOMITING-CONSULT MD. DO NOT FLAME CUT,
WELD, OR BRAZE ON COATED METAL WITHOUT A NIOSH/MSHA TC23C
RESPIRATOR. DO NOT ALLOW MA TERIAL TO FREE FALL MORE THAN 5 INCHES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A POSITIVE PRESS AIR SUPPLY RSPTR(TC19C
NIOSH/MSHA) IS RECM.IF NOT AVAIL,USE VAPOR/PARTICULATE RSPTR RECM
BY RSPTR SUPPLIER AS EFFECT FOR ISOCYANATE VAPORS & MISTS.WEAR
RSPTR WHOLE TIME SPRAYING & UNT IL ALL VAPORS & MISTS ARE GONE.
Ventilation:USE ADEQUATE VENT IN VOLUME & PATTERN TO KEEP LEL & TLV'S
BLW RECM LVL TO PRODUCE EXPLOSION/FIRE.GENERAL MECH(SUPP DATA)
Other Protective Equipment:PREVENT PROLONGED SKIN CONTACT TO
CONTAMINATED CLOTHING.
Work Hygienic Practices:N/K .
Supplemental Safety and Health
BOILING POINT:(127-164C). PH, ROUTES OF ENTRY & CARC:FP N. FIRE FIGHT
PROCEDURES:BUILD-UP & POSS AUTO IGN/EXPLN WHEN EXPOS TO EXTM HEAT.
FIRE EXPLN HAZ:PREC.DURING EMER SITUATION,OVEREXP TO DECOMP PRO D
MAY CAUSE HEALTH HAZ W/NO SYMP IMMED APPARENT.OBTAIN MED ATTN.
VENT:VENT SHOULD COMPLY W/OSHA 1910.94.NOTE:OLD FORMULA
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:260-327 F
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/K
Vapor Density:HTA
Spec Gravity:0.983
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:N/K
Appearance and Odor:N/K
Percent Volatiles by Volume:61.73
Corrosion Rate:
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACID, ALKALIES, AND OXIDIZERS.
Stability Condition to Avoid:HEAT, OPEN FLAMES, ELECTRICAL AND STATIC
DISCHARGE.
Hazardous Decomposition Products:UNKNOWN OTHER THAN CO*2 AND POSSIBLY
CO AND CARBON SMOKE,CN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE &
FEDERAL REGULATIONS. LAND FILL OR INCINERATE IN APPROVED FACILITY
BY LICENSED CONTRACTOR. DO NOT INCINERATE IN CLOSED CONTAINER.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:UCARTHERM HEAT TRANSFER FLUID PM-6141
CAGE:87578
CAGE:86511
CAGE:87578
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA III) *
CAS:107-21-1
RTECS #:KW2975000
OSHA PEL:C 50 PPM *
ACGIH TLV:C 50 PPM,VAPOR; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:WATER AND NON-HAZARDOUS ADDITIVES
Ingred Name:PHOSPHORIC ACID (SARA III) *
CAS:7664-38-2
RTECS #:TB6300000
OSHA PEL:1 MG/M3/3 STEL *
ACGIH TLV:1 MG/M3/3 STEL; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:POTASSIUM HYDROXIDE (SARA III) *
CAS:1310-58-3
RTECS #:TT2100000
OSHA PEL:C, 2 MG/M3 *
ACGIH TLV:C 2 MG/M3; 9192 *
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE:DISCOMFORT,REDNESS;SKIN:NO
KNOWN ADVERSE HEALTH EFFECTS;INHALATION:NOSE & THROAT
IRRITATION,HEADACHE,NAUSEA, VOMIT,DIZZINESS,IRREGULAR EYE
MOVEMENTS;INGESTION:ABDOMINAL DISCOMFORT OR PAIN,NA
USEA,VOMITING,DIZZINESS,DROWSINESS,MALAISE,BLURRED VISION,
IRRITABILITY,LUMBAR PAIN,OLIGURIA-SEE SUPPLEMENTAL DATA.
Explanation of Carcinogenicity:MANUFACTURER STATES NOT CARCINOGENIC.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES. SKIN: REMOVE
CONTAMINATED CLOTHING & FLUSH SKIN WITH WATER. INHALATION:REMOVE TO
FRESH AIR. SEE DOCTOR IF DISCOMFORT PERSISTS. INGESTION: IF
CONSCIOUS, GIVE 2 GL ASSES OF WATER AND INDUCE VOMITING. SEEDOCTOR
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:260F(127C)
Lower Limits:3.2 ETH GLY
Upper Limits:15.0 ETH GLY
Extinguishing Media:CO*2 OR DRY CHEMICAL FOR SMALL FIRES. ALCOHOL-TYPE
OR AL PURPOSE FOAM FOR LARGE FIRES.
Fire Fighting Procedures:WEAR SCBA & PROTECTIVE CLOTHING. DO NOT SPRAY
POOL FIRES DIRECTLY. A SOLID STREAM OF WATER OR FOAM DIRECTLY INTO
HOT,BURNING LIQUID CAN CAUSE FROTHING.
Unusual Fire/Explosion Hazard:NONE NOTE USE REASONABLE CARE.
================== Accidental Release Measures ==================
Spill Release Procedures:USE SUITABLE PERSONAL PROTECTION. SMALL SPILLS
SHOULD BE FLUSHED WITH LARGE QUANTITIES OF WATER AND RECOVERED FOR
PROPER DISPOSAL. SIMILARLY, LARGE SPILLS SHOULD BE COLLECTED FOR
PROPER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE PROPER PERSONAL PROTECTION. KEEP
AWAY FROM FLAMES AND HEAT AND TIGHTLY CLOSED WHEN NOT IN USE.
Other Precautions:AVOID CONTACT WITH EYES AND SKIN. DO NOT INGEST OR
BREATHE. MAY BE FATAL IF SWALLOWED. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR FOR ORGANIC
VAPORS/ SCBA IF NEEDED.
Ventilation:PROVIDE MECHANICAL (GENERAL/LOCAL EXHAUST) VENTILATION TO
MAINTAIN < TLV.
Other Protective Equipment:SAFETY SHOWER & EYE BATH
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
HEALTH HAZARD CONT'D:UREMIA,CNS EFFECTS, IRREGULAR EYE
MOVEMENTS,CONVULSIONS,COMA,CARDIAC FAILURE,PULMONARY EDEMA, KIDNEY
DAMAGE,DEATH. REPEATED OVEREXPOSURE:REPEATED INHALATION CAUSES
DIZZINESS & NYS TAGMUS;REPEATED SKIN CONTACT CAUSES DERMATITIS ON
SENSITIVE INDIVIDUALS-SEE CASE HISTORY 89013A FOR MORE HEALTH
INFORMAT
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:329F(165C)
Melt/Freeze Pt:M.P/F.P Text:-12F,-24C
Vapor Pres:1.2
Vapor Density:2.1,ETH.GL
Spec Gravity:1.133
Evaporation Rate & Reference:APPROX 0.1(BU AC=1)
Solubility in Water:100%
Appearance and Odor:YELLOW-GREEN LIQUID,GLYCOL ODOR
Percent Volatiles by Volume:96
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NORMALLY UNREACTIVE.HOWEVER,AVOID STRONG BASES,STRONG ACIDS,STRONG
OXIDIZING AGENTS & MATERIALS REACTIVE W/HYDROXYL COM
Stability Condition to Avoid:HEAT AND OPEN FLAME
Hazardous Decomposition Products:CO AND CO*2 ON BURNING
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR DISPOSE OF COLLECTED MATERIAL IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:MICROPOLISH II 0.05 MICRON, 40-6325-008/016/080
Resp. Party Other MSDS Num.:SERIAL # B2181
CAGE:09410
CAGE:09410
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM OXIDE (2:3); (GAMMA ALUMINA)
CAS:1344-28-1
RTECS #:BD1200000
> Wt:75.
Other REC Limits:N/K
OSHA PEL:15 MG/M3
OSHA STEL:N/K
ACGIH TLV:10 MG/M3
ACGIH STEL:N/K
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE IRRITATION OF
THE NOSE AND THROAT ACCOMPANIED BY COUGH AND CHEST PAIN. SKIN: NO
EVIDENCE OF ADVERSE EFFECTS. INGESTION: NO EVIDENCE OF ADVERSE
EFFECTS. EYES: MAY CAUSE IRRITATION SEEN AS REDNESS AND POSSIBLY
SWELLING OF THE CONJUNCTIVA.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:BREATHING OF DUST MAY AGGRAVATE
ASTHMA AND INFLAMMATORY OR FIBROTIC PULMONARY DISEASE.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN IF BREATHING IS
DIFFICULT. CALL A PHYSICIAN. SKIN: WASH THOROUGHLY WITH SOAP AND
WATER. INGESTION: RINSE MOUTH WITH WATER. EYES: FLUSH WITH WATER
FOR AT LE AST 15 MINUTES. SEEK MEDICAL ATTENTION IF DISCOMFORT
PERSISTS. NOTES TO PHYSICIAN: THERE IS NO SPECIFIC ANTIDOTE.
TREATMENT OF OVEREXPOSURE SHOULD BE DIRECTED AT THE CONTROL OF
SYMPTOMS AND THE CLINIC AL CONDITION.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Upper Limits:0.00%
Extinguishing Media:NOT APPLICABLE. USE MEDIA SUITABLE FOR SURROUNDING
FIRE .
Fire Fighting Procedures:NOT APPLICABLE. WEAR NIOSH APPROVED SCBA AND
FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT APPLICABLE. FLAMMABLE LIMITS: CLASS
1.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT TO PROTECT AGAINST
HAZARDS AND DISPOSE OF PER WASTE DISPOSAL METHOD.
======================Handling and Storage ======================
Other Precautions:KEEP DRY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF THERE IS EXCESSIVE DUSTINESS, WEAR A NIOSH
APPROVED RESPIRATOR SELECTED PER OSHA 29 CFR 1910.134.
Ventilation:LOCAL EXHAUST: LOCAL DUST PICKUP RECOMMENDED.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER .
Work Hygienic Practices:GOOD PERSONAL HYGIENE TO BE FOLLOWED AT ALL
TIMES.
Supplemental Safety and Health
PHYSICAL/CHEMICAL PROPERTIES: VOC: NONE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NONE
Vapor Density:NON VOLAT
Spec Gravity:1.00036 (H*2O=1)
Evaporation Rate & Reference:NON VOLATILE
Appearance and Odor:WHITE POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:NOT APPLICABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE PER LOCAL, STATE AND FEDERAL
REGULATIONS.
===================== Regulatory Information =====================
Federal Regulatory Information:ALL INGREDIENTS IN THIS PRODUCT ARE
LISTED IN THE TSCA INVENTORY. WHMIS REGULATION: CANADIAN WORKPLACE.
WHMIS CLASSIFICATION: CLASS D2B.
State Regulatory Information:
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:148B BULLETIN COLORS
CAGE:FO720
CAGE:92086
CAGE:FO720
============= Composition/Information on Ingredients =============
Ingred Name:RESIN
Fraction by Wt: 30-40%
Other REC Limits:10 MG/CUM (DUST)
Ingred Name:VM&P NAPHTHA (LIGROINE)
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 30-40%
Other REC Limits:STEL 400 PPM
OSHA PEL:300 PPM/400 STEL
ACGIH TLV:300 PPM; 9192
Ingred Name:LEAD (SARA III)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 5-10%
OSHA PEL:0.05 MG/M3;1910.1025
ACGIH TLV:0.15 MG/M3;DUST 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TERT-BUTYL CHROMATE
CAS:1189-85-1
RTECS #:GB2900000
Fraction by Wt: 1-5%
OSHA PEL:S, C 0.1MG/M3
ACGIH TLV:S, C 0.1MG/M3; 9192
Ingred Name:PIGMENT
CAS:6350-30-1
Fraction by Wt: 1-5%
Other REC Limits:10 MG/CUM (DUST)
Ingred Name:COBALT (SARA III)
CAS:7440-48-4
RTECS #:GF8750000
Fraction by Wt: <0.1%
Other REC Limits:0.05 PPM
OSHA PEL:0.1 MG/M3;AS CO
ACGIH TLV:0.05 MG/M3;DUST 9293
Ingred Name:METHYL ETHYL KETOXIME
CAS:96-29-7
RTECS #:EL9275000
Fraction by Wt: 0.1-1%
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: <0.1%
Other REC Limits:200 PPM
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ALIPHATIC ACIDS
Fraction by Wt: 0.1-1%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: DIZZINESS, GIDDINESS,
NARCOSIS, CENTRAL NERVOUS SYSTEM DEPRESSION, KIDNEY, LIVER, & OTHER
SYSTEMIC DAMAGE, AFFECT HIGHER BRAIN FUNCTIONS, MENTAL CAPACITY,
LUNG CANCER, PERFORATION OF THE N ASAL SEPTA. SKIN: REDNESS OR
SWELLING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: DIZZINESS, GIDDINESS, NARCOSIS,
CENTRAL NERVOUS SYSTEM DEPRESSION, KIDNEY, LIVER, & OTHER SYSTEMIC
DAMAGE, AFFECT HIGH BRAIN FUNCTIONS, MENTAL CAPACITY, LUNG CANCER,
PERFORATION OF THE NAS AL SEPTA. SKIN: REDNESS OR SWELLING.
Medical Cond Aggravated by Exposure:SKIN, LUNG, KIDNEY & LIVER
CONDITIONS
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, RESTORE
BREATHING. INGESTION: DON'T INDUCE VOMITING. EYE: FLUSH W/LARGE
QUANTITIES OF WATER FOR 15 MINS. SKIN: REMOVE EXCESS MATERIAL
W/PAPER TOWELS OR RAGS. WASH W/MILD SOAP & WARM WATER.OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:108F
Lower Limits:1%
Upper Limits:7%
Extinguishing Media:CO2 OR DRY CHEMICAL
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. WATER SPRAY
SHOULD BE USED TO COOL CONTAINERS EXPOSED TO FIRE. DON'T ENTER THE
FIRE AREA W/O PROPER PROTECTIVE EQUIPMENT/SCBA.
Unusual Fire/Explosion Hazard:AVOID SOURCE OF IGNITION, FLAME, STATIC
ELECTRICITY, HEAT, ELECTRICAL SPARK.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL HEAT SOURCES, OPEN FLAMES &
OTHER SOURCES OF IGNITION. ABSORB W/SOLID ABSORBENT. SHOVEL INTO
CONTAINERS. IF LARGE QUANTITIES ARE SPILLED, PERSONAL PROTECTIVE
EQUIPMENT MAY BE REQUIRED.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:HANDLE CAREFULLY IN ACCORDANCE W/HAZARDOUS PROPERTIES
OF FLAMMABLE LIQUIDS AS SUGGESTED BY THE NATIONAL FIRE PROTECTION
ASSOCIATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ORGANIC VAPOR RESPIRATOR W/PARTICULATE FILTER
APPROVED BY NIOSH.
Ventilation:LOCAL EXHAUST: PREFERRED-PAINT SPRAY BOOTH, 150 FPM FACE
VELOCITY. MECHANICAL ACCEPTABLE FOR SMALL VOLUME APPLICATIONS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:313-388F
Vapor Pres:2-15
Vapor Density:3.8-4.9
Spec Gravity:0.74-0.89
Evaporation Rate & Reference:(ETHER = 1): 9-70
Solubility in Water:INSOLUBLE
Appearance and Odor:WATER WHITE & CHARACTERISTIC PETROLEUM ODOR.
Percent Volatiles by Volume:25-35%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:SOURCE OF IGNITION, FLAME, STATIC
ELECTRICITY, EXCESSIVE HEAT, ELECTRICAL SPARK.
Hazardous Decomposition Products:CO, NITRIC OXIDE, LEAD, CHROMIUM FUME.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ACID DILUENT
Kit Part:Y
CAGE:77672
CAGE:77672
============= Composition/Information on Ingredients =============
Ingred Name:PHOSPHORIC ACID (SARA III)
CAS:7664-38-2
RTECS #:TB6300000
Fraction by Wt: 10-20%
OSHA PEL:1 MG/M3/3 STEL
ACGIH TLV:1 MG/M3/3 STEL; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 70-80%
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SOLVENT VAPORS MAY CAUSE
DROWSINESS,HEADACHE,DIZZINESS,AND IRRITATION OF EYES,NOSE AND
THROAT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:RESPIRATORY SYSTEM AILMENTS.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH LOTS OF WATER FOR 15 MINUTES;SKIN:REMOVE
CONTAMINATED CLOTHING,FLUSH WITH SOAP & WATER;INHALATION:REMOVE TO
FRESH AIR,GIVE O*2/CPR IF NECESSARY;INGESTION:DRINK MILK OF
MAGNESIA & LOTS OF WATER.SEE DOCTOR IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:55F,12.8C
Lower Limits:2.0
Extinguishing Media:SAND,FOAM,CO*2,CHEMICAL TYPES
Fire Fighting Procedures:AVOID BREATHING VAPORS OR FUMES.USE SCBA FOR
ENCLOSED AREAS.COOL FIRE EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:CONTAINER MAY EXPLODE IF EXPOSED TO HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION,WEAR APPROVED
RESPIRATOR,CONTAIN SPILL WITH INERT SUBSTANCE (SAND,DIRT),PUT
MIXTURE IN CONTAINERS FOR DISPOSAL.KEEP SPILL OUT OF SEWERS AND
OPEN BODIES OF WATER.
Neutralizing Agent:5% SODIUM BICARBONATE SOLUTION.
======================Handling and Storage ======================
Handling and Storage Precautions:GROUND CONTAINERS AND EQUIPMENT.EMPTY
CONTAINERS ARE HAZARDOUS,DO NOT CUT OR WELD.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROVED NIOSH/MSHA RESPIRATOR WHEN VAPOR
CONCENTRATIONS ARE ENCOUNTERED.
Ventilation:EXPLOSION PROOF EXHAUST VENTILATION AT POINT OF CONTAMINANT
RELEASE.
Other Protective Equipment:COVERALLS AND BOOTS
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:171F,78C
Vapor Pres:35/ALCOHOL
Vapor Density:>1
Spec Gravity:0.92
pH:LOW
Evaporation Rate & Reference:<1 (ETHER=1)
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID
Percent Volatiles by Volume:92
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALIES
Stability Condition to Avoid:HEAT,SPARKS,OPEN FLAMES
Hazardous Decomposition Products:CO,CO*2,ACID FUMES,OXIDES OF
PHOSPHORUS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW FEDERAL,STATE AND LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: EC 1756 THALO BLUE, ENHANCE 2000 (SUPDAT)
Cage: IO491
=======================================================
Contractor Summary
=======================================================
Cage: 01PD6
Cage: IO491
=======================================================
Ingredients
=======================================================
Cas: 25322-68-3
RTECS #: TQ3500000
% Wt: 10-20
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 56-81-5
RTECS #: MA8050000
% Wt: 1-5
OSHA PEL: 15 MG/M3 (MIST)
ACGIH TLV: 10 MG/M3 (MIST)
------------------------------
Cas: 132778-08-6
% Wt: 1-5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Cas: 1332-58-7
RTECS #: GF1670500
% Wt: 30-40
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 15 MG/M3 TDUST
------------------------------
Cas: 9005-64-5
RTECS #: TR7400000
POLY(OXY-1,2-ETHANEDIYL)DERIVS.)
% Wt: 1-5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 7732-18-5
RTECS #: ZC0110000
% Wt: 20-30
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 147-14-8
RTECS #: GL8510000
(29H,31H-PHTHALOCYANINATO(2-)N29,N30,N31,N32)-, (SP-4-1)-C32H16CUM8)
% Wt: 5-10
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
RTECS #: 9999999VO
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
STORAGE OR SALVAGE VESSELS. USE ABSORB TO
-----------------------------
OUT OF SEWERS & WATER COURSES. SM SPILLS:
-----------------------------
-----------------------------
INHALABLE PARTICLES SUCH AS SPRAYING OR
-----------------------------
AVOIDED, USE APPROP NIOSH APPRVD RESP PROT
-----------------------------
RESIDUES.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHAL: IRRIT OF RESPIRATORY TRACT. PROLONGED INHAL MAY
LEAD TO MUCOUS MEMBRANE IRRIT, COUGH, DIFFICULTY W/SPEECH, FEVER &
CHILLS, PULMONARY EDEMA, PNEUMOCONIOSIS. POSSIBLE SENSITIZATION TO
RESPIRATORY TRACT. SKIN CONTACT: IRRIT OF SKIN. PROLONGED OR REPEATED
CONTACT CAN CAUSE DERMATITIS. POSSIBLE (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ: SENSITIZATION TO SKIN. EYES.
PROLONGED OR REPEATED CONTACT CAN CAUSE BLURRED VISION, TEARING OF EYES.
INGEST: MAY CAUSE MUCOUS MEMBRANE IRRITATION, VOMITING, DIARRHEA, GI
DISTURBANCES.
Medical Cond Aggravated By Exposure: EYE, SKIN, RESPIRATORY DISORDERS, LUNG
DISORDERS, ASTHMA-LIKE CONDITIONS.
First Aid: INHAL: REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED
BREATHING. GET EMER MED ATTN. HAVE TRAINED PERSON GIVE OXYGEN IF NECESSARY.
GET MED HELP FOR ANY BREATHING DFCLTY. GET MED ATTN IF DISCOMFORT ORIRRIT
PERSISTS. SKIN: FLUSH FROM SKIN W/WATER. THEN WASH THOROUGHLY W/SOAP &
WATER. REMOVE CONTAMD CLTHG. WASH CONTAMD CLTHG BEFORE REUSE. IF IRRIT
OCCURS, CONSULT MD. EYES: FLUSH IMMED W/LG (SUPDAT)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: COMPLY W/ALL APPLIC HEALTH & ENVIRONMENTAL REGS.
ELIM ALL SOURCES OF IGNIT. VENT AREA. SPILLS MAY BE COLLECTED W/ABSORB MATLS.
PLACE COLLECTED MATL IN PROPER CNTNR. COMPLETE PERSONAL PROT EQUIP MUST B E
USED DURING CLEANUP. LG SPILLS: SHUT
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH ALL APPLICABLE FEDERAL,
STATE AND LOCAL REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
Handling And Storage Precautions: STORE BELOW 100F. KEEP FROM FREEZING. KEEP
AWAY FROM DIRECT SUNLIGHT, HEAT AND ALL SOURCES OF IGNITION.
Other Precautions: USE ONLY W/ADEQ VENT. DO NOT TAKE INTERNALLY. KEEP OUT OF
REACH OF CHILDREN. AVOID CONTACT W/SKIN & EYES & BRTHG OF VAPS. WASH
HANDS THOROUGHLY AFTER HNDLG, ESPECIALLY BEFORE EATING OR SMOKING. KEEP C
NTNRS TIGHTLY CLOSED & UPRIGHT
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONE
Extinguishing Media: DRY CHEMICAL OR FOAM WATER FOG. CARBON DIOXIDE.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT
(FP N). WATER MAY BE USED TO COOL AND PROTECT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard: CLOSED CNTNRS MAY BURST IF EXPOSED TO EXTREME
HEAT OR FIRE. MAY DECOMPOSE UNDER FIRE CNDTNS EMITTING IRRITANT &/OR
TOXIC GASES. IN CLSD TANKS, WATER OR (SUPDAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW APPLICABLE
STANDARDS. WHERE RESPIRATORY PROTECTION IS REQUIRED, USE ONLY NIOSH APPROVED
RESPIRATORS IN ACCORDANCE WITH OSHA STANDARD 29 CFR 1910.134.
Ventilation: PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT BUILD-UP
OF VAPORS.
Other Protective Equipment: ANSI APPROVED EYE WASH & DELUGE SHOWER (FP N).
IMPERVIOUS CLOTHING, APRON.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: MFR'S TRADE NAME/PART NO: COLORANTS EC 1700
SERIES. EXPLO HAZ: FOAM MAY CAUSE FROTHING OR ERUPTION. FIRST AID PROC: AMTS
OF WATER, ESP UNDER LIDS FOR AT LEAST 15 MIN. IF IRRIT/OTHER EFTS PERSIST,
OBTA IN MED TREATMENT. INGEST: IF SWALLOWED,OBTAIN MED TREATMENT IMMED.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >212F,>100C
Spec Gravity: 1.398 (FP N)
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume: 38.93
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: ELEVATED TEMPERATURES, CONTACT WITH OXIDIZING
AGENT, STORAGE NEAR ACIDS, FREEZING.
Materials To Avoid: OXIDIZERS, ACIDS, BASES, PEROXIDES, DEHYDRATING AGENTS.
NITRATES.
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE, OXIDES OF
NITROGEN, HYDROGEN CHLORIDE, TOXIC GASES.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: EC 1756 THALO BLUE, ENHANCE 2000 (SUPDAT)
Cage: IO491
Assigned IND: Y
Company Name: ICI PAINTS
Street: 925 EUCLID AVE
Zipcode: 44115
Label Required IND: Y
Date Of Label Review: 02/11/1998
Status Code: C
Label Date: 02/11/1998
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: INHALATION: IRRITATION OF RESPIRATORY TRACT,
MUCOUS MEMBRANE IRRITATION, COUGHING, DIFFICULTY WITH SPEECH, FEVER AND
CHILLS, PULMONARY EDEMA, PNEUMOCONIOSIS. SKIN: IRRITATION, DERMATITIS. EYES:
IRRITATION, BLURRED VISION, TEARING. INGESTION: MUCOUS MEMBRANE IRRITATION,
VOMITING, DIARRHEA, GI DISTURBANCES. CHRONIC: INHALATION: SENSITIZATION TO
RESPIRATORY TRACT. SKIN: SENSITIZATION.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:XEROX XT-25 DRY INK PLUS
Preparer's Name:R.L. SEVIGNY
CAGE:82784
CAGE:62754
CAGE:82784
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE, ACRYLATE COPOLYMER
CAS:25213-39-2
Fraction by Wt: 80-90%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYPROPYLENE
CAS:9003-07-0
RTECS #:TR5000000
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 10-15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192
Ingred Name:ACRYLIC COPOLYMER
CAS:25608-33-7
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICA, AMORPHOUS, DIATOMACEOUS EARTH, CONTAINING LESS THAN
1% CRYSTALLINE SILICA
CAS:61790-53-2
RTECS #:HL8600000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:20 MPPCF
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:KYNAR, 1,1-DIFLUOROETHANE HOMOPOLYMER
CAS:24937-79-9
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE; NO KNOWN HEALTH HAZARD WHEN
USED AS INTENDED IN A COPY MACHINE. MAY CAUSE IRRITATION OF
RESPIRATORY TRACT AND EYES UNDER VERY DUSTY CONDITIONS.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:INHAED: COUGHING, WHEEZING, SHORTNESS OF
BREATH. EYES: REDNESS, TEARING, BLURRED VISION, DISCOMFORT.
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:INHALED: REMOVE FROM EXPOSURE. IF SYMPTOMS DEVELOP, SEE
DOCTOR. EYES: FLUSH WITH LOTS OF WATER FOR 15 MINUTES. SEE DOCTOR.
INGESTED: IF CONSCIOUS, DRINK LOTS OF WATER. IF SYMPTOMS DEVELOP,
SEE DOCTOR. SKIN: WASH WITH SOAP AND WATER. IF SYMPTOMS DEVELOP.
SEE DOCTOR.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER FOG, CARBON DIOXIDE, DRY CHEMICAL, FOAM
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:MAY FORM EXPLOSIVE MIXTURES WHEN
SUSPENDED IN AIR. ALL IGNITION SOURCES SHOULD BE AVOIDED.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM OR SWEEP UP AS WITH ANY OTHER NON-TOXIC
POWDER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM STRONG OXIDIZING
AGENTS.
Other Precautions:AVOID EXCESS EXPOSURE TO HEAT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION.
Other Protective Equipment:NONE NORMALLY REQUIRED.
Work Hygienic Practices:WASH HANDS AFTER HANDLING.
Supplemental Safety and Health
AVOID BREATHING DUST IF SPILLED.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:160F,71C
Spec Gravity:1.0
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK POWDER WITH FAINT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE WITH COMMON MATERIALS WHICH IT COULD COME IN CONTACT DURING NORMAL
OPERATIONS.
Stability Condition to Avoid:OPEN FLAME
Hazardous Decomposition Products:TOXIC DECOMPOSITION PRODUCTS FORMED ON
COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:HI LITE LIQUID
CAGE:9K743
CAGE:9K743
============= Composition/Information on Ingredients =============
Ingred Name:HYDROGEN PEROXIDE
CAS:7722-84-1
RTECS #:MX0900000
Fraction by Wt: 30-35%
Other REC Limits:1 PPM
OSHA PEL:1.4 MG/CUM
ACGIH TLV:1.4 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. MAY CAUSE
IRREVERSIBLE TISSUE DAMAGE TO EYES, INCLUDING BLINDNESS. INGESTION:
IRRITATION TO GI TRACT.
Explanation of Carcinogenicity:NONE
Medical Cond Aggravated by Exposure:SENSITIVITIES, CARCINOGENICITY,
TERATOGENICITY, MUTAGENICITY, SYNERGISTIC PRODUCTS & ANY MEDICAL
CONDITION AGGRAVATED BY EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/PLENTY OF WATER FOR AT LEAST 15
MINS. LIFTING UPPER & LOWER LIDS INTERMITTEN. SKIN: WASH W/PLENTY
OF WATER. INGESTION: DRINK PLENTY OF WATER. DON'T INDUCE VOMITING.
OBTAIN ME DICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:WATER, WATER FOG, CO2, DRY CHEMICAL
Fire Fighting Procedures:STRONG OXIDIZER-FLOOD W/WATER
Unusual Fire/Explosion Hazard:HYDROGEN PEROXIDE ITSELF IS
NONCOMBUSTIBLE. ON DECOMPOSITION, RELEASES OXYGEN WHICH MAY
INTENSIFY FIRE. SMALL 14ML CONTANIER SIZE MINIMIZES ANY DANGER.
================== Accidental Release Measures ==================
Spill Release Procedures:WASH AREA W/PLENTY AMOUNT OF WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DARK PLACE. REFRIGERATE
TO PROLONG LIFE.
============= Exposure Controls/Personal Protection =============
Other Protective Equipment:PROTECTIVE CLOTHING
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>108C
Melt/Freeze Pt:M.P/F.P Text:-33C
Vapor Pres:23.3
Spec Gravity:1-13
Evaporation Rate & Reference:(BU AC = 1) >1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REDUCING AGENTS, RUST, DIRT, ORGANIC MATERIALS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DILUTE W/PLENTY OF WATER.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: TITANIUM PUTTY HARDENER, 10770
Cage: 16059
Resp. Party Other MSDS No.: 0619, PART NO. 0214
=======================================================
Contractor Summary
=======================================================
Cage: 16059
=======================================================
Ingredients
=======================================================
Cas: 32610-77-8
% low Wt: 30.
% high Wt: 50.
-----------------------------
Cas: 931-36-2
% low Wt: 5.
% high Wt: 10.
------------------------------
Cas: 112-24-3
RTECS #: YE6650000
% low Wt: 1.
% high Wt: 10.
------------------------------
Cas: 108-95-2
RTECS #: SJ3325000
< Wt: 5.
Other REC Limits: 5 PPM CANADA (MFR)
OSHA PEL: 19 MG/M3;5 PPM
ACGIH TLV: 19 MG/M3;5 PPM
ACGIH STEL: NOT ESTABLISHED
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 14807-96-6
RTECS #: WW2710000
% low Wt: 10.
% high Wt: 30.
Other REC Limits: NIOSH 2MG/M3 (MFR)
OSHA PEL: see Table Z-3
ACGIH TLV: 2 MG/M3
ACGIH STEL: NOT ESTABLISHED
------------------------------
Cas: 65997-17-3
% low Wt: 5.
% high Wt: 20.
OSHA PEL: 5 MG/M3 (RESIN)
ACGIH TLV: 10 MG/M3
------------------------------
Cas: 14808-60-7
RTECS #: VV7330000
< Wt: 1.
Other REC Limits: OSHA 0.1 MG/M3 (MFR)
OSHA PEL: see Table Z-3
ACGIH TLV: 0.1 MG/M3
ACGIH STEL: NOT ESTABLISHED
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50: (ORAL,RAT) >2200 MG/KG
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: ACUTE: SKIN: SEV IRRITANT. POTNTL SENSITIZER. EYES: SEV
IRRITANT. INHAL: IRRIT OF NOSE & THROAT; NAUS & VOMIT IN SEV CASES.
INGEST: MAY CAUSE BLEEDING OF GI TRACT & VOMIT OF BLOOD. CHRONIC: RPTD
SKINCONT CAN CAUSE SENSITIZ, W/ITCHING, RASHES/SWELL OF SKIN. TETA MAY
CAUSE RESP SENSITIZ & CHRONIC LUNG TOXICITY (COUGH, TIGHTNESS OF CHEST,
SHORTNESS OF BREATH). OTHER EFTS: RPTD AND/OR PRLNGD EXPOSURE TO LOW CONCS
OF VAP MAY CAUSE :SORE THROAT, EYE IRRIT, NAUS, FAINTNESS, HDCH, WHICH ARE
TRANSIENT. RPTD AND/OR PRLNGD EXPOSURES MAY RSLT IN: ADVERSE SKIN EFTS (SUCH
AS DEFAT, RASH, IRRIT OR CORR), AD VERSE EYE EFTS (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: SILICA., CRYSTALLINE-QUARTZ: IARC MONOGRAPHS,
SUPPLEMENT. VOL68 , PG 41, 1997: GROUP 1. NTP 7TH ANNUAL RPT ON CARCINOGENS,
1994: ANTICIPATED TO BE CARCINOGEN.
Signs And Symptions Of Overexposure: EFTS OF OVEREXP: (SUCH AS CONJ/CORNEAL
DMG). PHENOL IS HUMAN POISON BY INGESTION.
Medical Cond Aggravated By Exposure: ASTHMA. CHRONIC RESPIRATORY DISEASE (E.G.
BRONCHITIS, EMPHYSEMA). EYE DISEASE. SKIN DISORDERS AND ALLERGIES.
First Aid: EYES: IMMED FLUSH W/CLEAN WATER FOR AT LST 15 MINS WHILE GENTLY
HOLDING EYELIDS OPEN. GET MED HELP AS SOON AS POSSIBLE. SKIN: IMMED REMOVE
CONTAMD CLTHG & SHOES & WASH WELL W/SOAP & WATER. SEE MD IF I
RRIT DEVELOPS. INHAL: REMOVE TO FRESH AIR. GIVE OXYG/ARTF RESP IF NEEDED. SEE
MD IF SYMPTOMS PERSIST. INGEST: DO NOT INDUCE VOMIT. DILUTE W/LOTS OF
MILK/WATER & GET IMMEDIATE MEDICAL HELP.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: AVOID PERSONAL CONTACT. ELIM IGNIT SOURCES. VENTILATE
AREA. DIKE, CNTN & ABSORB W/CLAY, SAND OR OTHER SUITABLE MATL. FOR LG
SPILLS, PUMP TO STORAGE/SALVAGE VESSELS. SOAK UP RESIDUE W/ABSORB SUCH AS CL
AY, SAND, OR OTHER SUITABLE MATL & DISPOSE OF PROPERLY. FLUSH W/WATER TO
REMOVE TRACE RESIDUE. PVNT SPILL FROM ENTERING DRAINAGE/SEWER SYS, WATERWAYS,
& SURFACE WATERS.
Waste Disposal Methods: IF THIS MATERIAL BECOMES WASTE, IT WOULD NOT BE
HAZARDOUS WASTE BY RCRA CRITERIA (40CFR 261). DISPOSE OF ACCORDING TO
APPLICABLE FEDERAL, STATE, AND LOCAL REGULATIONS.
Handling And Storage Precautions: CONT W/SKIN, EYES/CLTHG. WASH THORO W/SOAP
& WATER AFTER USING & PARTICULARLY BEFORE EATING, DRINKING, SMOKING,
APPLYING COSMETICS/USING TOILET FACILITIES. LAUNDER CONTAMD CLTHG & PROT
GEAR BEFORE REU SE. DISCARD CONTAMD LEATHER ARTICLES.
Other Precautions: HNDL MIXED RESIN & HARDENER I/A/W POTNTL HAZARD OF
CURING AGENT USED. PROVIDE APPROP VENT/NIOSH APPRVD RESP PROT AGAINST DECOMP
PRODS(SEE STABILITY & REACTIVITY SECTION) DURING WELDING/FLAME CUTTING O
PEATIONS & TO PROTECT AGAINST SILICA DUST DURING SANDING/GRINDING OF
CURED PRODUCT. (SUPDAT)
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point: =136.1C, 277.F
Extinguishing Media: MEDIA SUITABLE FOR SURROUNDING FIRE (FP N).
Fire Fighting Procedures: USE NIOSH APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT
(FP N).
Unusual Fire/Explosion Hazard: TOXIC FUMES WILL BE RELEASED WHEN THIS MATL
BURNS OR IS THERMALLY DECOMPOSED. OXIDES OF CARBON, OXIDES OF NITROGEN,
AMMONIA AND UNIDENTIFIED ORGANIC COMBUSTION PRODUCTS.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE REQUIRED IN NORMAL USE WITH GOOD VENTILATION; IN
POORLY VENTILATED AREAS, WEAR NIOSH-APPROVED ORGANIC VAPOR MASK.
Ventilation: LOC EXHST IS REC FOR CONFINED AREAS & FOR PRLNGD/RPTD USE OF
PROD. GEN MECH VENT IS ADEQUATE FOR NORMAL USE.
Other Protective Equipment: OTHER PROTECTIVE GEAR AS REQUIRED TO PREVENT SKIN
CONTACT. EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN CRITERIA (FP N).
Work Hygienic Practices: WASH THORO W/SOAP & WATER AFTER USING & PARTICULARLY
BEFORE EATING, DRINKING, SMKNG, APPLYING COSMETICS/USING TOILET FACILITIES.
Supplemental Safety and Health: OTHER PREC: STORE IN COOL, DRY AREA AWAY FROM
HIGH TEMPERATURES AND FLAMES. PH: (5% SOLUTION/SLURRY IN WATER): 9.5-10.0.
VOC (GRAMS/LITER): 0.
=======================================================
Physical/Chemical Properties
=======================================================
Boiling Point: >176.7C, 350.F
Vapor Pres: <1 AT 70 F
Spec Gravity: 1.78
PH: SUPDAT
Solubility in Water: APPRECIABLE
Appearance and Odor: OFF-WHITE PASTE WITH AMMONIACAL ODOR.
Percent Volatiles by Volume: 0
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: EXPOSURE TO OPEN FLAME OR EXTREME HEAT.
Materials To Avoid: STRONG OXIDIZING AGENTS, ACIDS, AND CHLORINATED ORGANIC
COMPOUNDS.
Hazardous Decomposition Products: OXIDES OF NITROGEN AND CARBON, AMMONIA.
Hazardous Polymerization Indicator: YES
Conditions To Avoid Polymerization: HEAT IS RELEASED WHEN MATL IS MIXED W/EPOXY
RESIN; BE CAREFUL WHEN MIXING A POUND OR MORE.
=======================================================
Toxicological Information
=======================================================
Toxicological Information: ACUTE DERMAL EFTS: MOD IRRIT TO SKIN OF RABBIT.
PHENOL RAPIDLY ABSORB THRU SKIN & CAN CAUSE DEATH. EYE IRRIT: SEV IRRIT
OF RABBIT. OTHER CHRONIC EFTS: GEN OBSERVED IN ANIMAL STUDIES THAT
ALIPHATIC AMINES CAN CAUSE CHANGES IN LUNGS & HEART. TETA FOUND TO PROD
LIVER & KIDNEY DAMAGE& BRAIN CONGESTION IN DERMALLY EXPOSED ANIMALS.
2-ETHYL-4-METHYLLMIDAZOLE:ORAL LD50 (RAT): 3400 MG/KG; DERMAL LD50 (RABBIT):
>2000 MG/KG; INHAL LC50 4HR,(RAT): >10 MG/L. TRIETHYLENETETRAMINE: ORAL
LD50(RAT): 2460 MG/KG; DERMAL LD50(RABBIT): 850 MG/KG. PHENOL: ORAL
LD50(RAT): 317 MG/KG; DERMAL LD50(RABBIT): 850 MG/ KG; INHAL LC50 4HR, (RAT):
316 MG/M3.
=======================================================
Ecological Information
=======================================================
Ecological: MOBILITY AND PERSISTENCE: PHENOL: BIODEGRADABILITY = 99.5% AT 7
DAYS.
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: FOR PURPOSES OF SARA SECTION 312 HAZARDOUS
MATERIALS INVENTORY REPORTING, THE FOLLOWING HAZARD CLASSES APPLY TO THIS
MATERIAL: IMMEDIATE HEALTH HAZARD - DELAYED HEALTH HAZARD
Federal Regulatory Information: TSCA: ALL INGREDIENTS OF THIS PRODUCT ARE
LISTED, OR ARE EXEMPT FROM LISTING, ON THE TSCA INVENTORY. PHENOL: CERCLA RQ
(LBS): 1000.0.
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: TITANIUM PUTTY HARDENER, 10770
Cage: 16059
Company Name: DEVCON CORP
Street: 30 ENDICOTT ST
Zipcode: 01923-3753
Label Required IND: Y
Date Of Label Review: 09/08/1999
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Severe
Contact Hazard: Severe
Fire Hazard: Slight
Reactivity Hazard: Slight
Hazard And Precautions: HAZ POLYMERIZATION MAY OCCUR. ACUTE: SKIN: SEV IRRIT.
EYES: SEV IRRIT. INHAL: IRRIT OF NOSE & THROAT; NAUS & VOMIT.
INGEST: BLEEDING OF GI TRACT & VOMIT OF BLOOD. CHRONIC: CANCER HAZ.
CONTAINS SILI CA, CRYSTALLINE QUARTZ WHICH IS LISTED AS A HUMAN LUNG
CARCINOGEN (FP N). CAN CAUSE SKIN SENSITIZ, W/ITCHING, RASHES/SWELLING. RESP
SENSITIZ & LUNG TOXICITY, RPTD/PRLNGD EXPOS TO LOW CONCS OF VAP MAY
CAUSE: SORE THROAT, EYE IRRIT, NAUS, FAINTNESS, HDCH, WHICH ARE TRANSIENT.
RPTD/PRLNGD EXPOS MAY RSLT IN ADVERSE SKIN EFTS (SUCH AS DEFAT, RASH,
IRRIT/CORR), ADVERSE EYE EFTS (SUCH AS CONJ/CORNEAL DAM ). PHENOL HUMAN
POISON.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:OMEGABOND 200 (PART B/CATALYST)
Kit Part:Y
CAGE:29907
CAGE:29907
============= Composition/Information on Ingredients =============
Ingred Name:HEXAHYDROPHTHALIC ANHYDRIDE. FLASH POINT: 300F
Fraction by Wt: 40-50%
Ingred Name:PHTHALIC ANHYDRIDE. FLASH POINT: 305F
CAS:85-44-9
RTECS #:TI3150000
Fraction by Wt: <5%
OSHA PEL:2 PPM
ACGIH TLV:1 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CURING AGENTS; (NON-HAZARDOUS CURING AGENTS, PIGMENTS)
Fraction by Wt: 0-50%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:WARNING: EXTREME IRRITANT-MAY CAUSE
RESP DMG AT HIGH CONC. INHAL: VAPS MAY CAUSE IRRIT TO RESP TRACT,
AND MAY EXERT NARCOTIC/ANESTHETIC EFFECTS. EYE: SEVERE IRRITATION
UPON DIRECT CONTACT. SKIN: IRRIT ATION UPON DIRECT CONTACT; MAY BE
A MILD SENSIT. INGEST: HARMFUL IF SWALLOWED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. GIVE ARTF RESP IF NOT BRTHG. GIVE
OXYGEN IF BREATHING DFCLT. GET MD IMMEDIATELY. EYE: IMMEDIATELY
FLUSH WITH WATER FOR AT LEAST 15 MINUTES; GET MD. SKIN: REMOVE
CONTAMINATE D CLOTHING; WASH AFFECTED AREA WITH WATER. INGEST: GET
IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:310F,154C
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:HIGH CONCENTRATIONS OF DUST OR VAPOR MAY
CREATE AN EXPLOSIVE MIXTURE IN AIR. TOXIC VAPORS MAY BE EVOLVED
UPON EXPOSURE TO HEAT OR OPEN FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:SCRAPE/SHOVEL ABSORBED WASTE & ABSORB IN
CNTNRS. SCRUB AREA W/SOAPY WATER & RINSE. PVNT RINSES FROM ENTERING
DRAINS/OTHER WATERWAYS. SPILLED MATL & WATER RINSES ARE CLASSIFIED
AS CHEM WASTE, AND MUST BE DISPOSED OF I/A/W (SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE, KEEP REMOVED
FROM ANY HEAT OR OPEN FLAME. KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:KEEP AWAY FROM INTENSE HEAT, OPEN FLAMES.AVOID EYE
AND SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:FLEXIBLE DUCTWORK SHOULD EXTEND TO AREAS OF HIGH CONC TO
PVNT LOC BUILDUP OF VAP. EXPLO-PROOF VENT EQUIP (SUPP DATA)
Other Protective Equipment:PROTECTIVE CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPILL: CURRENT LOCAL, ST & FEDERAL REGS. VENT: SHOULD BE USED FOR LOCAL
VENTILATION.
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Pres:<1 MMHG
Vapor Density:HVR/AIR
Spec Gravity:1.45
Solubility in Water:SLIGHTLY SOLUBLE
Appearance and Odor:PURPLE PASTE.
Percent Volatiles by Volume:NEGL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ALCOHOLS, ALKALIES OR ALKALI METAL IONS. UNDERGOES
HYDROLYSIS WITH WATER TO FORM ACID.
Stability Condition to Avoid:STORAGE IN OPEN CNTNRS, EXPOS TO HEAT
AND/OR OPEN FLAME, UNCONTROLLED MIXING W/(OR EXPOS TO) INCOMPATIBLE
SUBSTANCES.
Hazardous Decomposition Products:CO, CO*2, NO*X.
==================== Disposal Considerations ====================
Waste Disposal Methods:SPILLED MATERIAL & WATER RINSES ARE CLASSIFIED
AS CHEMICAL WASTE, AND MUST BE DISPOSED OF IN ACCORDANCE WITH
CURRENT LOCAL, STATE, AND FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:URETHANE ENAMEL,BLACK, 826Y AH699 (99-U)
CAGE:DO229
CAGE:18873
CAGE:DO229
============= Composition/Information on Ingredients =============
Ingred Name:ETHER ESTER
Fraction by Wt: 33.0%
ACGIH TLV:100PPM(PER MFR)
Ingred Name:ALIPHATIC ESTER
Fraction by Wt: 27.0%
ACGIH TLV:400PPM(PER MFR)
Ingred Name:ALIPHATIC PETROLEUM DISTILLATE
Fraction by Wt: 3.0%
ACGIH TLV:100PPM(PER MFR)
Ingred Name:NON AQUEOUS SOLUTION,HAZARD UNKNOWN,UNIDENTIFIED; WT % BY
DIFFERENCE
Fraction by Wt: 37.0%
===================== Hazards Identification =====================
Effects of Overexposure:CAUSE COUGHING,CHEST PAINS & BREATHING
DIFFICULTY MAY OCCUR,EARLY SIGNS MAY BE MISTKN FOR A COLD.
======================= First Aid Measures =======================
First Aid:INHALATION:MOVE TO FRESH AIR TO IMPROVE BREATHING;SKIN:WASH
WITH SOAP & WATER.REMOVE CONTAMINATED CLOTHING;EYES:FLUSH WITH
WATER FOR AT LEAST 15 MIN.CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:20-73F (CC)
Lower Limits:1.0
Upper Limits:11.2
Extinguishing Media:CO*2, FOAM, DRY CHEM.
Fire Fighting Procedures:COOL CLOSED CONTNRS W/H*2O USING FOG NOZZLES.
Unusual Fire/Explosion Hazard:WARNING: VAPOR & SPRAY MISTS ARE HARMFUL
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE UNPROTECTED PERSONS. ELIM IGNITION
SOURCES. STOP LEAK. H*2O SPRAY COOL CONT/DIVERT SPILL FROM
FIRE/HEAT. PROVIDE VENTILATION. ABSORB W COMMERCIAL
ABSORBENT,SHOVEL INTO METAL DRUMS:LG SPILL:DI KE W COMMERCIAL
ABSORBENT,PUMP INTO COVERED DRUMS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT,SPARKS & OPEN
FLAMES.CLOSE CONTAINERS AFTER EACH USE.DO NOT STORE ABOVE 120F
Other Precautions:WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING OR
SMOKING;OBSERVE LABEL PRECAUTIONS;CONTAINERS SHOULD BE GROUNDED
WHEN POURING;ALLRGY-PRONE PERSONS MAY BE SENSITZD,SHOULD NOT BE
EXPOSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA RESP TC-19C IF AIR CONTMNANTS
CONTROL IS NOT FEASIBLE
Ventilation:LOCAL & MECH PROVIDE SUFFICIENT VENT TO KEEP BELOW TLV
LEVEL
Other Protective Equipment:USE APPROPRIATE INDUSTRIAL HYGIENE
PRACTICES.
Supplemental Safety and Health
MSDS FM MFR DATED:03/28/80
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:168-347F
Vapor Pres:1.2
Vapor Density:4.7
Spec Gravity:1.006
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:MODERATE
Appearance and Odor:LIQUID PAINT WITH CHARACTERISTIC ODOR
Percent Volatiles by Volume:69.3
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, CORROSIVES
Stability Condition to Avoid:HEAT, IGNITION SOURCES;DO NOT MIX ACTVTR
UNTIL READY TO USE.
Hazardous Decomposition Products:CO,CO*2,SMOKE,NITROGEN,OXIDES OF
NITROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:1436G145/PR1436G B-2 ACCELERATOR
CAGE:83574
CAGE:83574
============= Composition/Information on Ingredients =============
Ingred Name:DIMETHYL ACETAMIDE
CAS:127-19-5
RTECS #:AB7700000
Fraction by Wt: 35%
Other REC Limits:10 PPM
OSHA PEL:35 MG/CUM
ACGIH TLV:36 MG/CUM (SKIN)
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 20%
ACGIH TLV:2 MG/CUM (RESP DUST)
Ingred Name:CALCIUM CHROMATE;CALCIUM DICHROMATE (VI);CHROMIC ACID,
CALCIUM SALT *94-3*
CAS:14307-33-6
RTECS #:HX7630000
Fraction by Wt: 15%
OSHA PEL:0.5 MG/CUM
ACGIH TLV:0.5 MG/CUM
Ingred Name:CATALYST AMORPHOUS SILICA *94-3*
CAS:67762-90-7
Ingred Name:MAGNESIUM ALUMINUM SILICATE *94-3*
CAS:8031-18-3
ACGIH TLV:10 MG/CUM
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DIMETHYLACETAMIDE-EYES: BURNING,
POSSIBLE TRANSIENT CORNEAL INJURY. SKIN: HARMFUL/ABSORPTION.
INHALATION: MAY CAUSE LIVER/KIDNEY DAMAGE. PROLONGED EXPOSURE TO
HEXAVALENT COMPOUNDS MAY CAUSE PENETRATIN G ULCERS OF THE SKIN &
MUCOUS MEMBRANESOF THE NOSE & PERFORATION OF THE CARTILAGINOUS
NASAL SEPTUM.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:BURNING, TEARING, REDDENING.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LUKE WARM WATER FOR 15 MINS. SKIN: WASH W/SOAP
& WATER. INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION
IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:>200F
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER FOG
Fire Fighting Procedures:USE COMPLETE PERSONAL PROTECTION.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE & COVER THE SPILL W/A NON-OXIDIZABLE
ABSORBENT. SCOOP INTO CONTAINER. SPRINKLE SODIUM THIOSULFATE ON
RESIDUE. WORK INTO RESIDUE. SCOOP INTO DISPOSAL CONTAINER. CLEAN
AREA W/WATEER.
======================Handling and Storage ======================
Other Precautions:AVOID ALL SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN APPLYING IN ANY CIRCUMSTANCES LIKELY TO
PRODUCE AIRBORNE LEVEL OF HAZARDOUS INGREDIENTS IN EXCESS OF TLV,
USE AN ORGANIC VAPOR CARTRIDGE/AIR-SUPPLIED RESPIRATOR.
Ventilation:GENERAL TO MAINTAIN VAPOR < PEL.
Other Protective Equipment:POLYETHYLENE APRON/COVERALLS
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE
SMOKING/EATING. REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212-331F
Vapor Density:>1K
Spec Gravity:1.321
Appearance and Odor:BLACK PASTE
Percent Volatiles by Volume:75.7
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
EASILY OXIDIZABLE MATERIALS
Hazardous Decomposition Products:OXIDES OF CARBON & NITROGEN, CHROMIUM
COMPOUNDS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF SPILLAGE IN COMPLIANCE W/FEDERAL,
STATE & LOCAL REGULATIONS. EPA HAZARDOUS WASTE #: D007
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:BLT-110
CAGE:88236
CAGE:88236
============= Composition/Information on Ingredients =============
Ingred Name:COBALT (SARA III)
CAS:7440-48-4
RTECS #:GF8750000
OSHA PEL:0.1 MG/M3;AS CO
ACGIH TLV:0.05 MG/M3;DUST 9293
===================== Hazards Identification =====================
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
======================= First Aid Measures =======================
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
===================== Fire Fighting Measures =====================
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
================== Accidental Release Measures ==================
======================Handling and Storage ======================
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
SOURCE OF DATA-MIL HANDBOOK 600-1 SEP 76.SAFETY & HEALTH DATA DEVELOPED
BY DGSC-STF.
================== Physical/Chemical Properties ==================
HCC:A3
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-IN ACCORDANCE WITH
DOD REGULATIONS AND FEDERAL,STATE & LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SERMETEL 739
CAGE:EO921
CAGE:58913
CAGE:EO921
============= Composition/Information on Ingredients =============
Ingred Name:ALPHA-ALUMINA (ALUMINUM OXIDE) (EPA LISTS ONLY FIBROUS
FORMS) (SARA III)
CAS:1344-28-1
RTECS #:BD1200000
Fraction by Wt: 20%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 5-15%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
Effects of Overexposure:SKIN/EYES IRRITATION. TOXIC IF INGESTED. INHALE
OF ATOMIZED MIST MAY CAUSE IRRIT/MUCOUS MEMBRANES
======================= First Aid Measures =======================
First Aid:SKIN: RINSE AFFECTED AREA W/EXCESS WATER. FOR SEVERE CONTACT
OBTAIN MED ATT. EYES: IRRIGATE W/WATER FOR AT LEAST 15 MINS. OBTAIN
MED ATT. INGESTION: RINSE MOUTH THOROUGHLY W/WATER. DON'T INDUCE
VOMITI NG. INHALATION: REMOVE VICTIM TO FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WILL NOT BURN OR SUPPORT COMBUSTION.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB ONTO CLAY OR VERMICULITE. RINSE SPILL
AREA WITH WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN ORIGINAL CONTAINERS BETWEEN
40-90F (5-32C). DO NOT FREEZE.
Other Precautions:SERMETAL 739 IS A MIXTURE OF INORGANIC PIGMENTS
SUSPENDED IN AN AQUEOUS ALKALI SILICATE SOLUTION. BINDER IS
MISCIBLE W/WATERTHE PIGMENT IS INSOLUBLE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR RESPIRATOR IF SPRAY APPLIED.
Ventilation:LOCAL EXHAUST: 150FT 3/MIN. AIR VELOCITY
Other Protective Equipment:NONE
Supplemental Safety and Health
PH: 10-12
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:220F
Vapor Pres:23.
Vapor Density:0.7
Spec Gravity:1.4
Evaporation Rate & Reference:(H2O = 1) 1
Solubility in Water:MISCIBLE
Percent Volatiles by Volume:88%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS
==================== Disposal Considerations ====================
Waste Disposal Methods:FILTER PIGMENT AND DISPOSE OF AS HAZARDOUS WASTE
IN ACCORDANCE WITH APPLICABLE LOCAL, STATE, OR FEDERAL REGULATIONS.
DILUTE BINDER WITH EXCESS WATER AND ADJUST PH TO NEUTRALITY.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:194 7753,LIQUID DEVELOPER,PROCESS C-22,PT B
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM METABORATE; WT% RANGE 25-30%.
Fraction by Wt: 27.5%
Ingred Name:AQUEOUS SOLUTION,HAZARD UNKNOWN,UNIDENTIFIED COMPONENTS;WT%
BY DIFFERENCE
Fraction by Wt: 72.5%
===================== Hazards Identification =====================
Effects of
Overexposure:INHALE:UNKNOWN;EYES:BURNS;SKIN:IRRITATION,PROLONGED
CONTACT MAY CAUSE BURNS;INGEST:EXPECT HARMFUL.
======================= First Aid Measures =======================
First Aid:INHALE:REMOVE TO FRESH AIR,GIVE CPR/O*2 IF NEED;EYES:FLUSH W
LG AMTS H*2O FOR 15 MIN;SKIN;FLUSH W LG AMTS H*2O;INGEST:RINSE
MOUTH;GET IMMEDIATE MEDICAL ATTENTION FOR EYES OR INGEST.
===================== Fire Fighting Measures =====================
Extinguishing Media:SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CNTND BRTHG APP;H*2O SPRAY COOL
CONT.
Unusual Fire/Explosion Hazard:CONTAINERS MAY RUPTURE IN HEAT OF FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE UNPROTECTED PERSONS.STOP LEAK.H*2O
SPRAY HOT CONTAINERS.ABSORB WITH COMMERCIAL ABSORBENT,SHOVEL INTO
WASTE DISPOSAL CONTAINERS;LG SPILL:DIKE WITH COMMERCIAL
ABSORBENT,TRANSFER INTO WASTE DISP OSAL CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA;PROTECT FROM PHYSICAL DAMAGE & AVOID SKIN CONTACT.KEEP
CONTAINERS TIGHTLY CLOSED.AVOID STRONG ACIDS.
Other Precautions:REMOVE & WASH CONTAMINATED CLOTHING.MAINTAIN STRICT
HYGIENE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL REQUIREMENTS
Ventilation:NO SPECIAL REQUIREMENTS
Other Protective Equipment:FULL WORK CLOTHING;FACE SHIELD WHEN
USING/MIXING PRODUCT.
Supplemental Safety and Health
MSDS FROM MFG.DATED 12-7-77.PH IS APPROX 14;PART B OF TWO PART
PRODUCT,SAME NSN.
================== Physical/Chemical Properties ==================
HCC:B1
Boiling Pt:>100.C, 212.F
B.P. Text:>212F,>100C
Vapor Pres:17
Vapor Density:0.6
Spec Gravity:1.25
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR WHITE AQUEOUS MIXTURE;ODORLESS
Percent Volatiles by Volume:70
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID STRONG ACIDS
Stability Condition to Avoid:NONE NOTED
Hazardous Decomposition Products:NONE NOTED
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED CONTAINERS,PENDING
DISPOSAL.HANDLE & DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS.MFG SUGGEST FLUSH
TO SEWER WITH WATER.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:NITRIC ACID, 50-70%
CAGE:0TG10
CAGE:0TG10
Contract Num:SP0450-00-M-SF60
CAGE:1KH20
============= Composition/Information on Ingredients =============
Ingred Name:NITRIC ACID
CAS:7697-37-2
RTECS #:QU5775000
Minumum % Wt:65.
Maxumum % Wt:70.
OSHA PEL:5 MG/M3;2 PPM
ACGIH TLV:5.2 MG/M3;2 PPM
ACGIH STEL:10 MG/M3;4 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Minumum % Wt:30.
Maxumum % Wt:35.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:INHALATION:CORROSIVE! INHALATION OF
VAPORS CAN CAUSE BREATHING DIFFICULTIES & LEAD TO PNEUMONIA &
PULMONARY EDEMA, WHICH MAY BE FATAL. INGESTION: CORROSIVE!
SWALLOWING NITRIC ACID CAN CAUSE IMMEDIATEPAIN & BURNS OF THE
MOUTH, THROAT, ESOPHAGUS & GASTROINTESTINAL TRACT. SKIN:CORROSIVE!
CAN CAUSE REDNESS, PAIN & SEVERE SKIN BURNS. CONCENTRATED SOLUTIONS
CAUSE DEEP ULCERS & STAIN SKIN A YELLOW OR Y ELLOW-BROWN COLOR.
EYE: CORROSIVE! VAPORS ARE IRRITATING & MAY CAUSE DAMAGE TO THE
EYES. CONTACT MAY CAUSE SEVERE BURNS & PERMANANENTDAMAGE.
CHRONIC:EROSION OF TEETH & LUNG DAMAGE.
Effects of Overexposure:INHALATION: INHALATION OF VAPORS CAN CAUSE
BREATHING DIFFICULTIES & LEAD TO PNEUMONIA & PULMONARY EDEMA, WHICH
MAY BE FATAL. OTHER SYMPTOMS MAY INCLUDE COUGHING, CHOKING &
IRRITATION OF THE NOSE, THRO AT,& RESPIRATORY TRACT. INGESTION:
SWALLOWING CAN CAUSE IMMEDIATE PAIN & BURNS OF THE MOUTH, THROAT,
ESOPHAGUS & GASTROINTESTINAL TRACT. SKIN CAN CAUSE REDNESS, PAIN &
SEVERE SKIN BURNS. CONCENTRATED SOLUTIONS CAUSE DEEP ULCERS &
STAIN SKIN A YELLOW OR YELLOW-BROWN COLOR. EYE: VAPORS ARE
IRRITATING & MAY CAUSE DAMAGE TO THE EYES. CONTACT MAY CAUSE SEVERE
BURNS & PERMANANENT EYE DAMAGE.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE DISEASE, OR CARDIOPULMONARY DISEASE MAY BE MORE
SUSCEPTIBLE TO THE EFFECTS OF THIS SUBSTANCE.
======================= First Aid Measures =======================
First Aid:IMMEDIATE FIRST AID TREATMENT REDUCES THE HEALTH EFFECTS OF
THIS SUBSTANCE. INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING,
GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, GIVE
OXYGEN. CALL A PHYSICIAN. INGESTION: DO NOT INDUCE VOMITING! GIVE
LARGE QUANTITIES OF WATER OR MILK IF AVAILABLE. NEVER GIVE ANYTHING
BY MOUTH TO AN UNCONSCIOUS PERSON. GET MEDICAL ATTENTION
IMMEDIATELY. SKIN: MM EDIATELY FLUSH SKIN WITH PLENTY OF WATER FOR
AT LEAST 15 MINUTES WHILE REMOVING CONTAMINATED CLOTHING & SHOES.
WASH CLOTHING & THOROUGHLY CLEAN SHOES BEFORE REUSE. GET MEDICAL
ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY MAY BE USED TO KEEP FIRE EXPOSED
CONTAINERS COOL. DO NOT GET WATER INSIDE CONTAINER.
Fire Fighting Procedures:INCREASES THE FLAMMABILITY OF COMBUSTIBLE,
ORGANIC & READILY OXIDIZABLE MATERIALS. IN THE EVENT OF FIRE, WEAR
FULL PROTECTIVE CLOTHING & NIOSH-APPROVED SELF-CONTAINED BREATHING
APPARATUS WITH FULL FAC EPIECE OPERATED IN THE PRESSURE DEMAND OR
OTHER POSITIVE PRESSURE MODE. FIRE: NOT COMBUSTIBLE, BUT IS A
STRONG OXIDIZER.
Unusual Fire/Explosion Hazard:REACTS EXPLOSIVELY WITH COMBUSTIBLE
ORGANIC OR READILY OXIDIZABLE MATERIALS SUCH AS: ALCOHOLS,
TURPENTINE, CHARCOAL, ORGANIC REFUSE, METAL POWDER, HYDROGEN
SULFIDE, ETC. REACTS WITH MOST METALS TO REL EASE HYDROGEN GAS
WHICH CAN FORM EXPLOSIVE MIXTURES WITH AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA OF LEAK OR SPILL. WEAR
APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT. ISOLATE HAZARD AREA.
KEEP UNNECESSARY & UNPROTECTED PERSONNEL FROM ENTERING. CONTAIN &
RECOVER LIQUID WHEN POSSIBLE. NE UTRALIZE WITH ALKALINE MATERIAL
(SODA ASH, LIME). THEN ABSORB WITH AN INERT MATERIAL (E.G.,
VERMICULITE, DRY SAND, EARTH), & PLACE IN A CHEMICAL WASTE
CONTAINER. DO NOT USE COMBUSTIBLE MATERIALS.
Neutralizing Agent:NEUTRALIZE WITH ALKALINE MATERIAL (SODA ASH, LIME).
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, VENTILATED
STORAGE AREA WITH ACID RESISTANT FLOORS & GOOD DRAINAGE. PROTECT
FROM PHYSICAL DAMAGE. KEEP OUT OF DIRECT SUNLIGHT & AWAY FROM HEAT,
WATER, & INCOMPATIBLE MATERIALS. D O NOT WASH OUT CONTAINER & USE
IT FOR OTHER PURPOSES.
Other Precautions:WHEN DILUTING, THE ACID SHOULD ALWAYS BE ADDED SLOWLY
TO WATER & IN SMALL AMOUNTS. NEVER USE HOT WATER & NEVER ADD WATER
TO THE ACID. WATER ADDED TO ACID CAN CAUSE UNCONTROLLED BOILNG &
SPLASHING. CON TAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN EMPTY
SINCE THEY RETAIN PRODUCT RESIDUES(VAPORS, LIQU ID).
============= Exposure Controls/Personal Protection =============
Respiratory Protection:PERSONAL RESPIRATORS (NIOSH APPROVED): IF THE
EXPOSURE LIMIT IS EXCEEDED, WEAR A SUPPLIED AIR, FULL-FACEPIECE
RESPIRATOR, AIRLINED HOOD, OR FULL-FACEPIECE SELF-CONTAINED
BREATHING APPARATUS. NITRIC AC ID IS AN OXIDIZER & SHOULD NOT COME
IN CONTACT WITH CARTRIDGES & CANISTERS THAT CONTAIN OXIDIZABLE
MATERIALS, SUCH AS ACTIVATED CHARCOAL. CANISTER-TYPE RESPIRAT
Ventilation:A SYSTEM OF LOCAL &/OR GENERAL EXHAUST IS RECOMMENDED TO
KEEP EMPLOYEE EXPOSURES BELOW THE AIRBORNE EXPOSURE LIMITS. LOCAL
EXHAUST VENTILATION PREFERRED.
SPLASHING IS POSSIBLE.
Other Protective Equipment:WEAR IMPERVIOUS PROTECTIVE CLOTHING,
INCLUDING BOOTS, LAB COAT, APRON OR COVERALLS AS APPROPRIATE, TO
PREVENT SKIN CONTACT. MAINTAIN EYE WASH FOUNTAIN & QUICK-DRENCH
FACILITIES IN WORK AREA.
Work Hygienic Practices:USE IN A WELL VENTILATED AREA. AVOID CONTACT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:=122.C, 251.6F
Melt/Freeze Pt:=-42.C, -43.6F
Vapor Pres:48@20C(68F)
Vapor Density:2-3(AIR=1)
Spec Gravity:1.41
pH:1.0
Evaporation Rate & Reference:NO DATA FOUND.
Solubility in Water:INFINITELY SOLUBLE
Appearance and Odor:COLORLESS TO YELLOWISH LIQUID. SUFFOCATING, ACRID
ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
A DANGEROUSLY POWERFUL OXIDIZING AGENT, CONCENTRATED NITRIC ACID IS
INCOMPATIBLE WITH MOST SUBSTANCES, ESPECIALLY STRONG BASES,
METALLIC POWDERS, CARBIDES, HYDROGEN SULFIDE, TURPENTINE, AND
COMBUSTIBLE ORGANICS.
Stability Condition to Avoid:LIGHT AND HEAT. STABLE UNDER ORDINARY
CONDITIONS OF USE AND STORAGE. CONTAINERS MAY BURST WHEN HEATED.
Hazardous Decomposition Products:WHEN HEATED TO DECOMPOSITION, EMITS
TOXIC NITROGEN OXIDES FUMES AND HYDROGEN NITRATE. WILL REACT WITH
WATER OR STEAM TO PRODUCE HEAT AND TOXIC AND CORROSIVE FUMES.
Conditions to Avoid Polymerization:WILL NOT OCCUR
=================== Toxicological Information===================
Toxicological Information:INHALATION: RAT LC50 = 244 PPM( NO2/30M);
INVESTIGATED AS A MUTAGEN, REPRODUCTIVE EFFECTOR. ORAL HUMAN LDL0 =
430 MG/KG.
==================== Disposal Considerations ====================
Waste Disposal Methods:WHATEVER CANNOT BE SAVED FOR RECOVERY OR
RECYCLING SHOULD BE MANAGED IN AN APPROPRIATE & APPROVED WASTE
FACILITY. ALTHOUGH NOT A LISTED RCRA HAZARDOUS WASTE, THIS MATERIAL
MAY EXHIBIT ONE OR MORE CHAR ACTERISTICS OF A HAZARDOUS WASTE &
REQUIRE APPROPRIATE ANALYSIS TO DETERMINE SPECIFIC DISPOSAL REQUI
REMENTS. DISPOSE IAW LOCAL, STATE & FED REGS.
=================== MSDS Transport Information ===================
Transport Information:PSN: NITRIC ACID (WITH NOT MORE THAN 70% NITRIC
ACID), 8, UN2031, II.
===================== Regulatory Information =====================
SARA Title III Information:SEC 302: RQ= 1,000 LBS; TPQ = 1,000 LBS;
SARA 311/312 HAZ CATEGORIES: ACUTE, CHRONIC, FIRE = YES;
Federal Regulatory Information:NITRIC ACID IS LISTED ON THE TSCA
INVENTORY
State Regulatory Information:LISTED ON EC, JAPAN, AUSTRALIA, CANADA AN
PHILADELPHIA.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:835 0167 FLEXICOLOR STABILIZER & REPLENISHER LF
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 70 - 75%
Other REC Limits:NONE RECOMMENDED
Ingred Name:HEXAMINE/HEXAMETHYLENETETRAMINE
CAS:100-97-0
RTECS #:MN4725000
Fraction by Wt: 25 - 30%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM DODECYLBENZENE SULFONATE (CERCLA)
CAS:25155-30-0
RTECS #:DB6825000
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:DIPROPYLENE GLYCOL
CAS:110-98-5
RTECS #:UB8785000
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NONIONIC SURFACTANT
CAS:68145-97-2
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:1,2-BENZISOTHIAZOL-3(2H)-ONE/SUBSTITUTED THIAZOLIN-3-ONE
CAS:2634-33-5
RTECS #:DE4620000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN,
GASTROINTESTINAL TRACT. ACUTE- EYES/SKIN:MAY CAUSE IRRITATION.
INHALE:LOW HAZARD. IN ACIDIC CONDITION, THIS PRODUCT MAY RELEASE
FORMALDEHYDE WHICH MAY CAUSE RESPIRATORY SENSI TIZATION.
ORAL:HARMFUL IF SWALLOWED. MAY CAUSE GASTROINTESTINAL TRACT
IRRITATION. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, SENSITIZATION
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF
THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. EYES:FLUSH WITH WATER FOR 15 MINUTES, HOLDING EYELIDS OPEN.
CALL PHYSICIAN. SKIN:WASH WITH SOAP & PLENTY OF WATER. ORAL:DO NOT
INDUCE VOMITING. IF CONSCIOUS, DRINK 1 GLASS OF WATER. SEEK
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, ALCOHOL FOAM OR DRY
CHEMICAL. USE WATER SPRAY TO COOL FIRE EXPOSED CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. HAZARDOUS DECOMPOSITION
PRODUCTS MAY BE FORMED.
Unusual Fire/Explosion Hazard:MAY CAUSE DECOMPOSITION.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNT OF WATER.
OTHERWISE, ABSORB SPILL WITH INERT MATERIAL SUCH AS SAND OR
VERMICULITE, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN
SURFACE THOROUGHLY TO REMOVE RES IDUAL CONTAMINATION.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM INCOMPATIBLE
MATERIALS. KEEP CONTAINER TIGHTLY CLOSED. KEEP OUT OF REACH OF
CHILDREN.
Other Precautions:AVOID CONTACT WITH EYES, SKIN AND CLOTHING. USE WITH
ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING. THE ROUTINE
USE OF A NONALKALINE (ACID) TYPE OF HAND CLEANER AND REGULAR
CLEANING OF WORKING SURFACES WILL MINIMIZE SKIN REACTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF FORMALDEHYDE IS EMITTED ABOVE TLV, WEAR
NIOSH-APPROVED FULL FACEPIECE RESPIRATORY PROTECTION AGAINST
FORMALDEHYDE. IF RESPIRATORS ARE USED, A PROGRAM SHOULD BE
INSTITUTED TO ASSURE COMPLIANCE WITH OSHA STANDARD 29CFR
1910.134/1048.
Ventilation:GOOD GENERAL VENTILATION IS SUFFICIENT FOR MOST CONDITIONS
(10 ROOM VOLUMES PER HOUR).
Other Protective Equipment:EYE BATH, WASHING FACILITIES, SAFETY SHOWER
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
FORMULA CHANGED. FOR PREVIOUS FORMULATION, SEE PNI A, SAME NSN.
CONCENTRATE: KAN 965658.
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:>212F,>100C
Decomp Temp:Decomp Text:>563F,>295C
Vapor Pres:18 @ 68F
Vapor Density:0.6
Spec Gravity:1.06
pH:7.7
Solubility in Water:COMPLETE
Appearance and Odor:AMBER LIQUID - SLIGHT AMINE ODOR
Percent Volatiles by Volume:70- 75
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS
Stability Condition to Avoid:TEMPERATURES ABOVE 383F (195C)
Hazardous Decomposition Products:AMMONIA, FORMALDEHYDE, CARBON
MONOXIDE, CARBON DIOXIDE, OXIDES OF NITROGEN, OXIDES OF SULFUR
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE OR LOCAL REGULATIONS. FLUSH TO SEWER WITH LARGE
AMOUNT OF WATER.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: MARINE COUSTIFAB,150G-NL-SL
Cage: 52307
Box: 952
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 52307
Box: 952
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INGESTION: UNKNOWN. SKIN CONTACT: FIBERGLASS MAY CAUSE
IRRITATION. INHALATION: UNKNOWN. EYE CONTACT: FIBERGLASS MAY CAUSE
IRRITATION.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
First Aid: SKIN: IF IRRITATION DEVELOPS FLUSH WITH PLENTY OF WATER AND GET
MEDICAL ATTENTION. EYES: FLUSH WITH POTABLE WATER FOR AT LEAST 15 MINUTES.
SEE MD (FP N). INHALATION: REMOVE TO FRESH AIR. SUPPORT BREAT HING (GIVE
OXYGEN OR ARTIFICIAL RESPIRATION) (FP N). INGESTION: CALL MD IMMEDIATELY (FP
N).
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: PUT IN CONTAINER FOR DISPOSAL I/A/W FEDERAL, STATE
& LOCAL REGULATIONS. NOTE: THIS MATERIAL IS PRODUCED AS AN "ARTICLE" AS
DEFINED IN 29 CFR 1910.1200 & IS THEREFORE EXEMPT FROM HAZARDOUS
COMMUNICATIO NS ACT. SINCE THIS MATL DOES NOT RELEASE & WILL NOT RESULT
IN EXPOS TO HAZ CHEMICAL UNDER NORMAL CONDITIONS OF USE, NO MSDS IS REQUIRED.
THIS FORM IS PROVIDED ONLY AS A CONVENIENCE TO OUR CUSTOMERS.
Waste Disposal Methods: PUT IN CONTR FOR DISP I/A/W FED, STATE & LOC REGS.
NOTE: THIS MATL IS PRODUCED AS AN "ARTICLE" AS DEFINED IN 29 CFR 1910.1200
& IS THEREFORE EXEMPT FROM HAZ COMMUNICATIONS ACT. SINCE THIS MATL DOES
NO T RELEASE & WILL NOT RSLT IN EXPOS TO HAZ CHEM UNDER NORM CNDTNS OF
USE, NO MSDS IS REQD. THIS FORM IS PROVIDED ONLY AS A CONVENIENCE TO
CUSTOMERS.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: USE MEDIA SUITABLE FOR SURROUNDING FIRE (FP N).
Fire Fighting Procedures: WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: DOES NOT BURN.
=======================================================
Control Measures
=======================================================
Respiratory Protection: WEAR NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N).
Other Protective Equipment: ANSI APPROVED EMERGENCY EYEWASH AND DELUGE SHOWER
(FP N).
Supplemental Safety and Health: PHYSICAL/CHEMICAL PROPERTIES: DENSITY: 120
#/CU. FT.
=======================================================
Physical/Chemical Properties
=======================================================
Solubility in Water: NONE
Appearance and Odor: DARK GRAY/BLACK SOLID; NO ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE KNOWN.
Hazardous Decomposition Products: NONE.
Hazardous Polymerization Indicator: NO
=======================================================
Other Information
=======================================================
Other Information: CHEMICAL FAMILY: MODIFIED SILICONE ELASTOMER ON FIBERGLASS
ON FOIL SCRIM CLOTH. FORMULA: MIXTURE.
=======================================================
HAZCOM Label
=======================================================
Product ID: MARINE COUSTIFAB,150G-NL-SL
Cage: 52307
Company Name: THE CLAREMONT COMPANY
Street: 174 STATE STREET
PO Box: 952
Zipcode: 06450
Label Required IND: Y
Date Of Label Review: 11/02/1999
Status Code: A
Origination Code: F
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: None
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: INGESTION: UNKNOWN. SKIN CONTACT: FIBERGLASS
MAY CAUSE IRRITATION. INHALATION: UNKNOWN. EYE CONTACT: FIBERGLASS MAY
CAUSE IRRITATION. CHRONIC: NONE SPECIFIED BY MANUFACTURER (FP N).
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:HYVAR X-L HERBICIDE
CAGE:DO229
CAGE:18873
CAGE:DO229
============= Composition/Information on Ingredients =============
Ingred Name:BROMACIL
CAS:314-40-9
RTECS #:YQ9100000
Fraction by Wt: 21.9%
OSHA PEL:1 PPM
ACGIH TLV:10 MG/M3; 9192
Ingred Name:ETHYLENE GLYCOL (SARA III)
CAS:107-21-1
RTECS #:KW2975000
OSHA PEL:C 50 PPM
ACGIH TLV:C 50 PPM,VAPOR; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
CAS:67-56-1
RTECS #:PC1400000
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL ALCOHOL (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9192
===================== Hazards Identification =====================
Effects of Overexposure:EYE:IRR,MILD CORNEAL OPACITY;SKIN:IRR;INHH:IRR
NOSE,THROAT;ING:HARMFUL IF SWALLOWED.FATAL.
======================= First Aid Measures =======================
First Aid:REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEED. SKIN:WASH WITH
SOAP & WATER. EYES:FLUSH WITH WATER 15 MIN. KEEP WARM AND QUIET.
ING:GIVE 2 GLASSES OF WATER.INDUCE VOMIT.NOTHING BY MOUTH IF
UNCONSC.SEE D R.IMM.
===================== Fire Fighting Measures =====================
Flash Point:111F,44C,SCC
Extinguishing Media:WATER SPRAY,CHEMICAL FOAM,DRY CHEMICAL,CO*2
Fire Fighting Procedures:WEAR SELF-CNTD BRTHG,APP H*20 SPRAY TO COOL
CONTR.
Unusual Fire/Explosion Hazard:COMBUSTIBLE.HEATING CAN RELEASE VAPORS
WHICH CAN BE IGNITED-SEE SUPPLEMENTAL DATA
================== Accidental Release Measures ==================
Spill Release Procedures:USE APPROP PERS.PROTECT.DURING CLEAN UP.DIKE
SPILL.PREVENT LIQ.FROM ENTERING SEWERS,WTRCOURSES.ABSORB W.INERT
MATL-IF SPILL IS ON GND NEAR VALUABLE TREES,REMOVE 2 INCHES OF SOIL
AFTER INITIAL CLEANUP.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY WELL VENTED LOW FIRE
RISK AREA. PROTECT FROM HEAT,SHOCK,FRICTION. KEEP CONTAINERS
CLOSED.
Other Precautions:DO NOT STORE WITH OTHER FERTILIZERS,PESTICIDES,FOOD
OR FEED.DO NOT STORE OR CONSUME FOOD,DRINK OR TOBACCO IN AREA WHERE
THEY MAY BECOME CONTAMINATED WITH THIS MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:APPVD PESTICIDE RESPIRATOR IF TLV IS EXCEEDED.
Ventilation:USE ONLY W.ADEQUATE VENTILATION.
Other Protective Equipment:NORMAL WORK CLOTHING COVERING ARMS & LEGS.
Supplemental Safety and Health
MSDS 04-03-86/UNUSUAL FIRE&EXPL. HAZ:IF AREA IS HVLY EXPSD TO FIRE&IF
CONDITIONS PERMIT,LET FIRE BURN ITSELF OUT SINCE WTR MAY INCREASE
THE AREA CONTAMINATED/LD50 ORAL RAT=1414MG/KG/PH=11.7/
================== Physical/Chemical Properties ==================
HCC:F4
Vapor Pres:NIL
Appearance and Odor:AMBER LIQUID,ALCOHOLIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS &AMINES,ESPECIALLY PRIMARY AMINES.
Stability Condition to Avoid:NONE NOTED
Hazardous Decomposition Products:NONE NOTED,BUT EXPECT CO, CO*2, H*2O.
DECOMPOSES W.HEAT
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT FLUSH TO SURF.WTR OR SEWERS.TRIPLE RINSE
CONTAINER.THEN OFFER FOR RECYCLE OR RECONDITIONING OR
PUNCTURE&DISPOSE OF IN SANIT.LANDFILL OR INCINER,OR IF ALLOWED
BURNING.COMPLY W.ALL APPLICABLE LOC AL,STATE AND FEDERAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:POWER CLEANER 310L/55 GALLON
CAGE:56883
CAGE:56883
============= Composition/Information on Ingredients =============
Ingred Name:MANUFACTURER LISTS NOTHING UNDER "INGREDIENTS" IMPLYING
THAT THERE ARE NO HAZARDOUS INGREDIENTS PER HAZ COM STD.
RTECS #:9999999ZZ
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EXPOSURE MAY CAUSE EYE, SKIN &
RESPIRATORY TRACT IRRITATION. INGESTION MAY IRRITATE GI TRACT.
CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:EYES-IRRITATION. SKIN-IRRITATION.
INHALED-IRRITATION. INGESTION-IRRITATION, DIARRHEA.
Medical Cond Aggravated by Exposure:DERMATITIS.
======================= First Aid Measures =======================
First Aid:EYES-FLUSH WITH WATER FOR 15 MINUTES. GET IMMEDIATE MEDICAL
ATTENTION. SKIN-REMOVE CONTAMINATED CLOTHES. FLUSH WITH WATER. SEE
DOCTOR IF IRRITATION PERSISTS. INHALED-REMOVE TO FRESH AIR.
ADMINISTER OX YGEN OR ARTIFICIAL RESPIRATION AS NEEDED. GET MEDICAL
ATTENTION. INGESTED-IF CONSCIOUS, GIVE WATER OR MILK. GET IMMEDIATE
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NONE SPECIFIED BY MANUFACTURER. DLA-HMIS: USE MEDIA
APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT MATERIAL TO SOAK UP AND THEN
PLACE IN A CONTAINER FOR LATER DISPOSAL. KEEP OUT OF SEWERS OR
WATERWAYS. IF ENTERS SEWER OR WATERWAY, NOTIFY NATIONAL RESPONSE
CENTER AT 800-424-8802.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. KEEP FROM
FREEZING. DO NOT STORE NEAR STRONG ACIDS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:NONE NORMALLY REQUIRED.
Other Protective Equipment:WHEN SPRAYING PRODUCT;RUBBER
BOOTS,APRONS,GAUNTLETS OR RAIN GEAR MAY BE
APPROPRIATE.DLA-HMIS:EYES WASH/EMERGENCY SHOWER.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:AS WATER
Vapor Density:AS WATER
Spec Gravity:1.14
pH:12.0
Evaporation Rate & Reference:1 (WATER=1)
Solubility in Water:APPRECIABLE
Appearance and Odor:CLEAR, FAINT YELLOW LIQUID; MILD ODOR.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS.
Stability Condition to Avoid:STRONG ACIDS.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL ENVIRONMENTAL REGULATIONS. NOT A RCRA HAZWASTE AS
PURCHASED. SARA III (311/312): NOT APPLICABLE; SARA III (313):
NONE.
| 1 |
gloves_mandatory
|
=======================================================
NIIN: 01-297-6282
Product ID: NICKEL CADMIUM BATTERY
Article: Y
Cage: 5V977
Box: UNKNOW
Resp. Party Other MSDS No.: ASSEMB: 7916940-00BATTERY: 7916604-00
=======================================================
Contractor Summary
=======================================================
Cage: 5V977
Box: UNKNOW
=======================================================
Item Description Information
=======================================================
Item Manager: S9G
Item Name: BATTERY ASSEMBLY
Unit of Issue: EA
Quantitative Expression: NOT AVAILABLE
UI Container Qty: 10
=======================================================
Regulated Components
=======================================================
Regulated Component Name: COBALT (AS COBALT METAL (CAS 7440-48-4), COBALT OXIDE
(CAS 1307-96-6), COBALT HYDROXIDE (CAS 21041-93-0))
Percent Text: 0.5-2%
Regulated Component Name: LITHIUM HYDROXIDE
CAS: 1310-65-2
Percent Text: 0-4%
Regulated Component Name: NICKEL (AS NICKEL METAL (CAS 7440-02-0), NICKEL OXIDE
(CAS 1313-99-1), NICKEL HYDROXIDE (CAS 12054-48-7))
Percent Text: 20-32%
Regulated Component Name: POTASSIUM HYDROXIDE
CAS: 1310-58-3
Percent Text: 0-4%
Regulated Component Name: SODIUM HYDROXIDE
CAS: 1310-73-2
Percent Text: 0-4%
Regulated Component Name: CADMIUM (AS CADMIUM METAL (CAS 7440-43-9), CADMIUM
OXIDE (CAS 1306-19-0), CADMIUM HYDROXIDE (CAS 21041-95-2))
Percent Text: 13-22%
=======================================================
Health Hazards Data
=======================================================
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: YES
Effects of Exposure: INGESTION: CONTENTS OF OPEN BATTERY CAN CAUSE SERIOUS
CHEMICAL BURNS OF MOUTH, ESOPHAGUS, & GASTROINTESTINAL TRACT.
INHALATION: RESPIRATORY IRRITATION. CADMIUM OXIDE FUMES CAN CAUSE METAL FUME
FEVER. HYPERSENSITIVITY TO NICKEL CAN CAUSE ALLERGIC PULMONARY ASTHMA. SKIN:
CAN CAUSE SKIN IRRITATION &/OR CHEMICAL BURNS. CAN CAUSE SKIN
SENSITIZATION & AN ALLERGIC CONTACT DERMATITIS. EYE: CAN CAUSE SEVE RE
IRRITATION & CHEMICAL BURNS.
Explanation Of Carcinogenicity: NICKEL, CADMIUM, NICKEL COMPOUNDS, CADMIUM
COMPOUNDS, AND COBALT COMPOUNDS ARE LISTED AS POSSIBLE CARCINOGENS BY
INTERNATIONAL AGENCY FOR RESEARCH ON CANCER (IARC) OR NATIONAL TOXICOLOGY
PROGRAM (NTP) .
Signs And Symptions Of Overexposure: INGESTION: CONTENTS INCLUDE TOXIC CADMIUM
& CADMIUM COMPOUNDS CAN CAUSE SALIVATION, CHOKING, NAUSEA, PERSISTENT
VOMITING, DIARRHEA, ABDOMINAL PAIN, DIZZINES, FAINTNESS, UNCONSCIOUSNESS,
& POSSIBLE LIV ER & KIDNEY INJURY.
First Aid: INGESTION: DO NOT INDUCE VOMITING OR GIVE FOOD OR DRINK. SEEK
MEDICAL ATTENTION IMMEDIATELY. CALL NATIONAL BATTERY INGESTION HOTLINE FOR
ADVICE & FOLLOW-UP (202-625-3333) COLLECT, DAY OR NIGHT.INHAL ATION:
PROVIDE FRESH AIR & SEEK MEDICAL ATT'N. SKIN: REMOVE CONTAMINATED
CLOTHING & WASH SKIN WITH SOAP & WATER. IF A CHEMICAL BURN OCCURS OR
IF IRRITATION PERSISTS, SEEK MEDICAL ATT'N. EYES: IMMEDI ATELY FLUSH EYES
THOROUGHLY WITH WTER FOR AT LEAST 15 MIN, LIFTING UPPER & LOWER LIDS,
UNTIL NO EVIDENCE OF THE CHEMICAL REMAINS. SEEK MEDICAL ATT'N.
=======================================================
Handling and Disposal
=======================================================
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH ALL APPLICABLE FEDERAL,
STATE AND LOCAL REGULATIONS. WHEN GENERATED AS A WASTE, THESE BATTERIES MAY
BE REGULATED BY THE RESOURCE CONSERVATION AND RECOVERY ACT (RCRA) AS A D0 06
(CADMIUM) HAZARDOUS WASTE. RECYCLING OF THIS PRODUCTMAY BE AVAILABLE. CAN
CALL 1-800-8-BATTERYFOR INFORMATION.
Handling And Storage Precautions: BATTERY SHOULD NOT BE OPENED. SHOULD A CELL
BECOME DISASSEMBLED, THE ELECTRODE SHOULD BE STORED IN A FIREPROOF CABINET,
AWAY FROM COMBUSTIBLES. STORE IN A COOL, WELL VENTILATED AREA. ELEVATED
TEMPERA TURES CAN RESULT IN SHORTENED BATTERY LIFE.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: FLOOD AREA W/ WATER. IF BATTERIES BURNING, WATER MAY NOT
EXTINGUISH, BUT WILL COOL ADJACENT BATTERIES & CONTROL SPREAD OF FIRE.
CO2, DRY CHEMICAL, & FOAM EXTINGUISHERS MAY BE USED.
Fire Fighting Procedures: FIRE FIGHTERS SHOULD WEAR SELF-CONTAINED BREATHING
APPARATUS. BURNING NICKEL-CADMINUM BATTERIES CAN PRODUCE TOXIC FUMES
INCLUDING NICKEL, NICKEL OXIDES, CADMIUM OXIDES, AND COBALT OXIDES.
Unusual Fire/Explosion Hazard: WHEN WATER IS USED HOWEVER, HYDROGEN GAS WILL BE
EVOLVED WHICH CAN FORM AN EXPLOSIVE MIXTURE IN A CONFINED SPACE. METL-X
(GRAPHITE BASE) WILL EXTINGUISH BURNING NICKEL CADMIUM BATTERIES AS WILL
SAND, DRY GROUND DOLOMITE OR SODA ASH. THESE MATERIALS ACT AS SMOTHERING
AGENTS.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT NECESSARY UNDER NORMAL CONDITIONS.
Ventilation: NOT NECESSARY UNDER NORMAL CONDITIONS.
LEAKING BATTERY.
LEAKING BATTERY.
Supplemental Safety and Health: BATTERY SHOULD NOT BE OPENED OR BURNED.
EXPOSURE TO THE INGREDIENTS CONTAINED WITHIN OR THEIR COMBUSTION PRODUCTS
COULD BE HARMFUL. SHOULD A CELL BECOME DISASSEMBLED, THE ELECTRODE SHOULD BE
STORED IN A FIREPROOF CABINET, AWAY FROM COMBUSTIBLES.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: Z5
=======================================================
Reactivity Data
=======================================================
Materials To Avoid: FIRE & COMBUSTIBLES.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
Transport Information: THE TRANSPORTATION OF DRY CELL BATTERIES MANUFACTURED OR
SOLD BY EVERREADY BATTERY COMPANY IS NOT REGULATED BY THE U.S. DEPARTMENT OF
TRANSPORTATION OR THE MAJOR INTERNATIONAL REGULATORY BODIES.
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: AS AN ARTICLE, THIS BATTERY AND ITS CONTENTS ARE
NOT SUBJECT TO THE REQUIREMENTS OF THE EMERGENCY PLANNING AND COMMUNITY
RIGHT-TO-KNOW ACT.
=======================================================
Other Information
=======================================================
Other Information: THE FEDERAL UNIVERSAL WASTE RULE CITED AT 40 CFR PART 273
GOVERNS NICKEL CADMIUM BATTERY RECYCLING AND MAY BE APPLICABLE IN YOUR STATE.
=======================================================
Transportation Information
=======================================================
Trans ID NO: 150514
Product ID: NICKEL CADMIUM BATTERY
Review Date: 12/04/1999
Multiple KIT Number: 0
Unit Of Issue: EA
Container QTY: 10
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: NICKEL CADMIUM BATTERY
Cage: 5V977
Company Name: ENERGIZER POWER SYSTEMS DIV OF EVEREADY BATTERY CO INC
Street: US HIGHWAY 441N
PO Box: UNKNOW
Zipcode: 32615
Label Required IND: Y
Date Of Label Review: 12/04/1999
Status Code: A
Origination Code: F
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: TARGET ORGANS: N/P. INGESTION: CONTENTS OF OPEN
BATTERY CAN CAUSE SERIOUS CHEMICAL BURNS OF MOUTH, ESOPHAGUS, &
GASTROINTESTINAL TRACT. INHALATION: RESPIRATORY IRRITATION. CADMIUM OXIDE
FUMES CAN CA USE METAL FUME FEVER. HYPERSENSITIVITY TO NICKEL CAN CAUSE
ALLERGIC PULMONARY ASTHMA. SKIN: CAN CAUSE SKIN IRRITATION &/OR CHEMICAL
BURNS. CAN CAUSE SKIN SENSITIZATION & AN ALLERGIC CONTACT DERMATITIS .
EYE: CAN CAUSE SEVERE IRRITATION & CHEMICAL BURNS.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:35529 LEMON 64
CAGE:EO320
CAGE:12120
CAGE:EO320
============= Composition/Information on Ingredients =============
Ingred Name:DIDECYL DIMETHYL AMMONIUM CHLORIDE; DIMETHYLDIDECYLAMMONIUM
CHLORIDE; BTC 1010; BARDAC 22
CAS:7173-51-5
RTECS #:BP6560000
Fraction by Wt: 2.31%
Ingred Name:QUATERNARY AMMONIUM COMPOUNDS, BENZYL-C12-18-ALKYLDIMETHYL,
CHLORIDES *96-1*
CAS:68391-01-5
Fraction by Wt: 1.54%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: BURNING, TEARING & IRRITATION.
INHALATION: NAUSEA, HEADACHE, IRRITATION OF NASAL PASSAGES.
INGESTION: NAUSEA, GASTRO-INTESTINAL DISTURBANCES. SKIN: REDNESS,
DRYNESS, IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: BURNING, TEARING & IRRITATION.
INHALATION: NAUSEA, HEADACHE, IRRITATION OF NASAL PASSAGES.
INGESTION: NAUSEA, GASTRO-INTESTINAL DISTURBANCES. SKIN: REDNESS,
DRYNESS, IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH THOROUGHLY W/WATER. REMOVE ANY CONTACT LENSES.
CONTINUE TO FLUSH W/WATER FOR 15 MINS. INHALATION: MOVE TO FRESH
IAR. INGESTION: DON'T INDUCE VOMITING. DRINK LARGE AMOUNTS OF WATER
& MILK. SKIN: WASH THOROUGHLY W/SOAP & WATER. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:MOP UP MATERIAL/PICK UP W/ABSORBENT. RINSE
W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN.
Other Precautions:IF DILUTED PRODUCT IS TO BE USED IN SPRAY/MIST FORM,
AVOID INHALATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF DILUTED PRODUCT IS TO BE USED IN SPRAY/MIST
FORM, USE A DUST MASK/RESPIRATOR.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:EYEWASH, PROTECTIVE CLOTHING
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Spec Gravity:1.01
pH:8-9
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR YELLOW LIQUID W/PLEASANT FRAGRANCE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:OXIDES OF CARBON & NITROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL OF THE CONCENTRATE IS REGULATED UNDER
RCRA AS A CORROSIVE WASTE. DISPOSE OF IN A PERMITTED FACILITY
IAW/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
=======================================================
NIIN: 01-336-3980
Product ID: ECO SURE GREEN 14062 GLOSS VOC-COMPLIANT SP
Cage: 0FTT5
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 0FTT5
=======================================================
Contractor Summary
=======================================================
Cage: 0FTT5
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: ENAMEL
Specification Number: A-A-2787
Unit of Issue: PT
UI Container Qty: 0
=======================================================
Ingredients
=======================================================
Cas: 1330-20-7
RTECS #: ZE2100000
% Wt: <19.84
Other REC Limits: NONE SPECIFIED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 100 PPM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 110-12-3
RTECS #: MP3850000
% Wt: 5.83
Other REC Limits: NONE SPECIFIED
OSHA PEL: 100 PPM
ACGIH TLV: 50 PPM; 9293
------------------------------
Cas: 64742-95-6
RTECS #: SE7546500
% Wt: <2.92
Other REC Limits: NONE SPECIFIED
OSHA PEL: 5 PPM
ACGIH TLV: 5 PPM
------------------------------
Cas: 64742-95-6
RTECS #: SE7546500
% Wt: 5.83
Other REC Limits: NONE SPECIFIED
OSHA PEL: 50 PPM
ACGIH TLV: 50 PPM
------------------------------
Cas: 108-10-1
RTECS #: SA9275000
% Wt: 2.92
Other REC Limits: NONE SPECIFIED
OSHA PEL: 100 PPM/75 STEL
ACGIH TLV: 50 PPM/75 STEL; 9293
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 107-87-9
RTECS #: SA7875000
% Wt: 2.92
Other REC Limits: NONE SPECIFIED
OSHA PEL: 200 PPM
ACGIH TLV: 200 PPM
------------------------------
Cas: 95-63-5
RTECS #: DC3325000
% Wt: <2.92
Other REC Limits: NONE SPECIFIED
OSHA PEL: 25 PPM
ACGIH TLV: 25 PPM
-----------------------------
Cas: 74-98-6
RTECS #: TX2275000
% Wt: 15.12
Other REC Limits: NONE SPECIFIED
OSHA PEL: 1000 PPM
ACGIH TLV: 1000 PPM
------------------------------
Cas: 75-28-5
RTECS #: TZ4300000
% Wt: 5.95
Other REC Limits: NONE SPECIFIED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 800 PPM
------------------------------
Cas: 106-97-8
RTECS #: EJ4200000
% Wt: 3.72
Other REC Limits: NONE SPECIFIED
OSHA PEL: 800 PPM
ACGIH TLV: 800 PPM
------------------------------
RTECS #: 9999999VO
Other REC Limits: NONE SPECIFIED
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE; CONCENTRATING & INHALING CONTENTS MAY BE
HARMFUL/FATAL. HIGH CONCENTRATIONS ARE ANESTHETIC. IRRITATION TO SKIN &
RESPIRATORY TRACT. OVEREXPOSURE MAY RESULT IN LIGHT HEADEDNESS, STAGGERING,
GIDD INESS, NAUSEA. HARMFUL IF SWALLOWED. SEVERE EYE IRRITATION. IRRITATION
TO EYES, THROAT. HEADACHES, NAUSEA, VOMITING.
Signs And Symptions Of Overexposure: CHRONIC; REPORTS HAVE ASSOCIATED REPEATED
& PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN
& NERVOUS SYSTEM DAMAGE.
Medical Cond Aggravated By Exposure: RESPIRATORY AILMENTS.
First Aid: FOR CONTACT WITH SKIN OR CLOTHES WASH WITH SOAP & WATER; WASH
CLOTHES BEFORE REUSE. FOR CONTACT WITH EYES, FLUSH WITH WATER FOR 15 MINUTES
& CONTACT A PHYSICIAN/OPHTHALMOLOGIST IMMEDIATELY. IF SWALLOW ED, DO NOT
INDUCE VOMITING. GET IMMEDIATE MEDICAL AID. IF INHALED, REMOVE TO FRESH AIR
& GIVE ARTIFICIAL RESPIRATION IF NECESSARY & GET MEDICAL AID. NEVER
GIVE ANYTHING BY MOUTH TO UNCONSCIOUS PERSON.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION AND VENTILATE AREA.
MOP SPILLS WITH INERT ABSORBENT. AVOID BREATHING VAPORS.
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH FEDERAL, STATE & LOCAL
REGULATIONS. DO NOT PUNCTURE, BURN OR STORE ABOVE 120F. EXPOSURE TO HEAT OR
PROLONGED EXPOSURE TO SUN MAY CAUSE CAN TO BURST. DISCARD EMPTY CAN IN TRA SH
PICK-UP. DO NOT PLACE IN HOME TRASH COMPACTOR.
Handling And Storage Precautions: KEEP OUT OF REACH OF CHILDREN! CAUTION -
CONTENTS UNDER PRESSURE. DO NOT STORE ABOVE 120 F. AVOID BREATHING SPRAY,
MIST OR VAPOR.
Other Precautions: AVOID CONTACT WITH EYES OR SKIN. USE WITH GOOD VENTILATION.
READ ENTIRE LABEL BEFORE USING. FOLLOW ALL LABEL DIRECTIONS. INTENTIONAL
MISUSE BY DELIBERATELY CONCENTRATING AND INHALING OR SWALLOWING CON TENTS MAY
BE HARMFUL OR FATAL.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NR
Autoignition Temp Text: 467.8C
Lower Limits: 1.8
Upper Limits: 9.5
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, SAND, WATER SPRAY.
AVOID SPREADING ANY BURNING LIQUID WITH WATER SPRAY.
Fire Fighting Procedures: WATER MAY BE INEFFECTIVE, USE TO KEEP FIRE EXPOSED
CNTNR COOL. WEAR SCBA. USE SHIELDING TO PROTECT PERSONNEL AGAINST BURSTING,
RUPTURING OR VENTING OF CNTNR.
Unusual Fire/Explosion Hazard: DO NOT SPRAY NEAR OPEN FLAME. AT ELEVATED
TEMPERATURE (OVER 120F) CONTAINERS MAY VENT, RUPTURE OR BURST. AEROSOL
CONTAINER; DO NOT EXPOSE TO TEMPS ABOVE 120 F.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE BELOW TLV. USE NIOSH/MSHA APPROVED MASK ABOVE TLV.
Ventilation: LOCAL EXHAUST: PREFERRED. MECHANICAL (GENERAL): ACCEPTABLE AT
POINT OF MIST OR SPRAY RELEASE.
Other Protective Equipment: IMPERVIOUS CLOTHES TO PROTECT SKIN. EYE WASH
STATION.
Work Hygienic Practices: USE GOOD PERSONAL HYGIENE. DO NOT EAT, DRINK, OR SMOKE
WHILE USING PRODUCT.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: V3
Vapor Pres: 60 @ 68F
Vapor Density: >1.5
Spec Gravity: 0.997 (WATER=1)
Solubility in Water: INSOLUBLE
Appearance and Odor: GREEN/PAINT
Percent Volatiles by Volume: 67
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: EXTREME HEAT
Hazardous Decomposition Products: CARBON MONOXIDE
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 126891
Product ID: ECO SURE GREEN 14062 GLOSS VOC-COMPLIANT SP
Review Date: 03/22/1993
Tech Entry NOS Shipping Nm: UN 1950 AEROSOL
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: PT
Container QTY: 0
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: DTJ
Symbols: D
DOT Proper Shipping Name: CONSUMER COMMODITY
Hazard Class: ORM-D
Label: NONE
Non Bulk Pack: 156,306
Bulk Pack: NONE
Max Qty Pass: 30KGGROSS
Max Qty Cargo: 30KGGROSS
Vessel Stow Req: A
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: AKH
IMO Proper Shipping Name: AEROSOLS/AEROSOL PRODUCT ?
IMDG Page Number: SEE 9022
UN Number: 1950
UN Hazard Class: 9?
IMO Packaging Group: -
Subsidiary Risk Label: -
EMS Number: 2-13
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ALS
IATA UN ID Num: 1950
IATA Proper Shipping Name: AEROSOLS, FLAMMABLE
IATA PSN Modifier: (EACH NOT EXCEEDING 1 L CAPACITY)
IATA UN Class: 2.1
IATA Label: FLAMMABLE GAS
Packing Note Passenger: 203
Max Quant Pass: 75KG
Max Quant Cargo: 150KG
Packaging Note Cargo: 203
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ALS
AFI Proper Shipping Name: AEROSOLS, NONFLAMMABLE, N.O.S.
AFI PSN Modifier: CONTAINING SUBSTANCES IN CLASS 8, PACKING GROUP I OR II
AFI Hazard Class: FORB
Back Pack Reference: FORBIDDEN
=======================================================
HAZCOM Label
=======================================================
Product ID: ECO SURE GREEN 14062 GLOSS VOC-COMPLIANT SP
Cage: 0FTT5
Company Name: LHB INDUSTRIES
Street: 8833 FLEISCHER PLACE
Zipcode: 63134
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: ACUTE; CONCENTRATING & INHALING CONTENTS MAY BE
HARMFUL/FATAL. HIGH CONCENTRATIONS ARE ANESTHETIC. IRRITATION TO SKIN &
RESPIRATORY TRACT. OVEREXPOSURE MAY RESULT IN LIGHT HEADEDNESS, STAGGERING,
GIDD INESS, NAUSEA. HARMFUL IF SWALLOWED. SEVERE EYE IRRITATION. IRRITATION
TO EYES, THROAT. HEADACHES, NAUSEA, VOMITING. CHRONIC; REPORTS HAVE
ASSOCIATED REPEATED & PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS
WITH PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
=======================================================
| 1 |
gloves_mandatory
|
=======================================================
Product ID: AM0808 CEFAZOLIN SODIUM
Cage: GO399
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: GO399
Assigned Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: GO399
Cage: 75602
=======================================================
Ingredients
=======================================================
Cas: 27164-46-1
RTECS #: XI0390000
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ALLERGIC REACTIONS HAVE BEEN REPORTED, WHICH MAY INCLUDE
EYE IRRITATION.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: RASH, NASAL CONGESTION, COUGH, DRY THROAT,
GASTROINTESTINAL UPSET, IRRITATION, ANAPHYLACTIC SHOCK.
Medical Cond Aggravated By Exposure: PENICILLIN/CEPHALOSPORIN HYPERSENSITIVITY.
First Aid: EYES: FLUSH W/PLENTY OF WATER. SKIN: WASH W/PLENTY OF SOAP &
WATER. INHALATION: MOVE TO FRESH AIR. IF NOT BREATHING, PROIDE CPR IF
NECESSARY. INGESTION: DON'T INDUCE VOMITING. ADMINISTER ACTIVATED CHA RCOAL
(6-8 HEAPING TEASPOONFULS) W/TWO TO THREE GLASSES OF WATER. DON'T GIVE
ANYTHING BY MOUTH IF UNCONSCIOUS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: CONTAIN DRY MATERIAL BY SWEEPING UP/VACUUMING USING A
DUST COLLECTION FILTER. BE AWARE OF DUST EXPLOSION WHEN USING ELECTRICAL
EXPOSURE.
Waste Disposal Methods: DISPOSE OF ANY CLEANUP MATERIALS & WASTE RESIDUE IN
ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
Handling And Storage Precautions: UNDER NORMAL USE & HANDLING CONDITIONS,
NO PROTECTIVE EQUIPMENT IS REQUIRED.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: WATER, CO2, DRY CHEMICAL, FOAM/HALON
Unusual Fire/Explosion Hazard: AS A FINELY DIVIDED MATERIAL, MAY FORM EXPLOSIVE
DUST MIXTURES IN AIR WHICH COULD EXPLODE IF SUBJECTED TO A SOURCE OF
IGNITION.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE AN APPROVED RESPIRATOR. IN PRODUCTION,
AIRLINE-SUPPLIED, HOOD-TYPE RESPIRATORS ARE PREFERRED.
Ventilation: LABORATORY FUME HOOD/LOCAL EXHAUST
Other Protective Equipment: CHEMICAL RESISTANT CLOTHING, SAFETY GLASSES
Work Hygienic Practices: REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health: PH (10% SOLUTION): 4.5-6.
=======================================================
Physical/Chemical Properties
=======================================================
PH: (SUPP)
Solubility in Water: COMPLETE
Appearance and Odor: WHITE TO OFF-WHITE CRYSTALLINE POWDER W/NO ODOR
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEAT
Materials To Avoid: STRONG OXIDIZING AGENTS
Hazardous Decomposition Products: TOXIC FUMES WHEN HEATED
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: AM0808 CEFAZOLIN SODIUM
Cage: GO399
Assigned IND: Y
Company Name: LILLY ELI & CO PHARMACEUTICAL DIV
Street: LILLY CORPORATE CENTER
Zipcode: 46285
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: ALLERGIC REACTIONS HAVE BEEN REPORTED, WHICH MAY
INCLUDE EYE IRRITATION.
RASH, NASAL CONGESTION, COUGH, DRY THROAT, GASTR
OINTESTINAL UPSET, IRRITATION, ANAPHYLACTIC SHOCK.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:XL MICROCEL
CAGE:53472
CAGE:53472
============= Composition/Information on Ingredients =============
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (TALC)
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 40-45%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:STYRENE (SARA III)
CAS:100-42-5
RTECS #:WL3675000
Fraction by Wt: 16%
OSHA PEL:100 PPM
ACGIH TLV:S,50PPM/100STEL;9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:MALEIC ANHYDRIDE, PHTHALIC ANHYDRIDE, ADIPIC ACID, PROPYL
GLYCOL DIETHYLENE GL POLYMER; (POLYESTER RESIN)
CAS:25464-21-5
Fraction by Wt: 35-40%
Other REC Limits:50 PPM (MFR)
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 0-1%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:NON HAZARDOUS INGREDIENT (NONHAZARDOUS MICRO SPHERES)
Fraction by Wt: 6-10%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:THE STYRENE IN PUTTY CAN IRRITATE
EYES, NOSE, THROAT & RESPIRATORY TRACT. EXTREME OVEREXPOSURE TO
STYRENE CAUSES NARCOSIS.
Explanation of Carcinogenicity:STYRENE:IARC GRP 2B, VOLUME 7, PAGE 345,
1987.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR & CONTACT MD. EYES:FLUSH FOR AT
LEAST 15 MINUTES W/WATER; CALL MD. SKIN:WASH W/SOAP & WATER.
INGEST:INDUCE VOMITING; CONTACT MD.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:>113F,>45C
Lower Limits:1.1%
Upper Limits:6.1%
Extinguishing Media:DRY POWDER, FOAM, CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . EXTINGUISH FLAME FROM PERIMETER INWARD
TOWARD MAIN BODY OF FIRE.
Unusual Fire/Explosion Hazard:FINE POLYESTER RESIN IN PUTTY CAN UNDERGO
EXOTHERMIC POLYMERIZATION. VIOLENT RUPTURE MAY RESULT IF CONTAINER
OF PUTTY IS CAUGHT IN A FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF OPEN FLAME. SCRAPE UP
PUTTY. REMAINDER MAY BE CLEANED W/HOT SOAPY WATER OR NON-FLAMMABLE
SOLVENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PROLONGED OR REPEATED CONTACT
W/SKIN. AVOID CONTACT W/EYES. STORE IN COOL, DRY AREA.
Other Precautions:DO NOT STORE IN DIRECT SUNLIGHT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED CANISTER OR AIR-PACK
(SELF-CONTAINED AIR SUPPLY).
Ventilation:LOCAL EXHAUST &/OR MEHANICAL (GENERAL):MUST BE WELL
VENTILATED. HOOD OVER WORKING AREA.
Other Protective Equipment:NOT NORMALLY NEEDED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
THIS IS A REFORMULATION. PART NUMBER INDICATOR "B" DENOTES NEWER
PRODUCT THAN "A", 8030-00-N00-6894. INGREDIENTS & OTHER CHANGES
APPLY .
================== Physical/Chemical Properties ==================
HCC:F8
Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:5.2
Vapor Density:3.6
Spec Gravity:1.08 (H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE TO GRAY PUTTY W/SWEET ODOR.
Percent Volatiles by Volume:17.5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:EXPOSURE TO EXCESSIVE HEAT OR OPEN FLAMES.
Hazardous Decomposition Products:CARBON MONOXIDE & LOW MOLECULAR WEIGHT
HYDROCARBONS.
Conditions to Avoid Polymerization:EXPOSURE TO EXCESSIVE HEAT OR OPEN
FLAME.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . MATERIAL TO BE DISPOSED OF BY BURYING IN EPA APPROVED
LANDFILL OR BURNING IN LICENSED EPA APPROVED INCINERATOR.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:GASOLINE, UNLEADED (ALL GRADES)
Preparer's Name:DAVID R. SCHONAUER
CAGE:6G072
CAGE:6G072
============= Composition/Information on Ingredients =============
Ingred Name:GASOLINE - PRODUCT MIXTURE CONTAINING THE FOLLOWING
INGREDIENTS:CAS:8006-61-9
RTECS #:LX3300000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:300 PPM/500 STEL
ACGIH TLV:300 PPM/500STEL;9293
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: <20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BENZENE (SARA III)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: <6%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1PPM/5STEL;1910.1028
ACGIH TLV:10 PPM; A2; 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:1,2,4-TRIMETHYLBENZENE (SARA III)
CAS:95-63-6
RTECS #:DC3325000
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:25 PPM
ACGIH TLV:25 PPM; 9293
Ingred Name:ETHYL BENZENE (SARA III)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: <3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM/125 STEL
ACGIH TLV:100 PPM/125STEL 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS >5G/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INHALATION: MODERATE RISK OF VAPOR
INTOXICATION. MAJOR RISK IS ENCLOSED SPACES WITH POOR VENTILATION.
SKIN: DEFATTING WITH DRYING AND CRACKING CAN LEAD TO DERMATITIS AND
SECONDARY INFECTION. EYE: IRRI TANT. INGESTION: BURNING OF MOUTH
AND UPPER GI TRACT, VOMITING AND DIARRHEA. PROLONGED OR REPEATED
CONTACT: DERMATITIS.
Explanation of Carcinogenicity:CONTAINS B[71-43-2] WHICH IS
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:INHALATION MAY CAUSE EUPHORIA, LUNG IRRITATION
AND EDEMA, HEADACHE, DIZZINESS, DROWSINESS, CONVULSIONS, COMA,
CYANOSIS, GENERALIZED DEPRESSION. INGESTION MAY CAUSE GENERAL
DEPRESSION, SEDATION, RESPIR ATORY DEPRESSION, COMA.
Medical Cond Aggravated by Exposure:MAY AGGRAVATE PRE-EXISTING
DERMATITIS, RESPIRATORY ILLNESS, OR OTHER CONDITIONS WHICH HAVE THE
SAME SYMPTOMS OR EFFECTS AS STATED ABOVE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH RUNNING WATER FOR 15 MINUTES WHILE HOLDING
EYELIDS OPEN. SKIN: REMOVE CONTAMINATED CLOTHING. WASH SKIN WITH
SOAP AND WATER. INHALATION: REMOVE TO FRESH AIR. FOR RESPIRATORY
DISTRESS, GIVE AIR, OXYGEN, OR CPR IF NECESSARY. INGESTION: DO NOT
INDUCE VOMITING. KEEP HEAD BELOW HIPS IF VOMITING OCCURS TO PREVENT
ASPIRATION INTO LUNGS. GET MEDICAL ATTENTION IF REQUIRED IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-40F,-40C
Lower Limits:1.4
Upper Limits:7.6
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE ON FLAMES, BUT SHOULD
BE USED TO KEEP FIRE-EXPOSED CONTAINERS COOL. LARGE FIRES, SUCH AS
TANK FIRES, SHOULD BE FOUGHT WITH CAUTION.
Unusual Fire/Explosion Hazard:HIGHLY VOLATILE MATERIAL. FLOWING
GASOLINE CAN BE IGNITED BY SELF-GENERATED STATIC ELECTRICITY.
VAPORS MAY TRAVEL ALONG THE GROUND TO A REMOTE IGNITION SOURCE.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: TAKE UP WITH NON COMBUSTIBLE ABSORBENT
SUCH AS FULLERS EARTH OR SAND. PLACE INTO CONTAINERS FOR LATER
DISPOSAL. LARGE: CONTAIN SPILL IN EARTHEN DIKES FOR LATER RECOVERY.
CONTROL IGNITION SOURCE S AROUND SPILL AREA. REPORT SPILLS AS
REQUIRED.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID STATIC IGNITION HAZARD WHEN
TRANSFERRING MATERIAL. KEEP CONTAINERS CLOSED AND AWAY FROM HEAT &
IGNITION SOURCES! DO NOT USE AS CLEANING AGENT.
Other Precautions:EMPTY CONTAINERS RETAIN SOME LIQUID/VAPOR RESIDUES;
HAZARD PRECAUTIONS MUST BE OBSERVED WHEN HANDLING EMPTIES. KEEP OUT
OF REACH OF CHILDREN! DO NOT USE ANY HYDROCARBON FUEL IN SPACES
WITHOUT ADEQUATE VENTILATION. USE ONLY AS A FUEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH/MSHA APPROVED ORGANIC VAPOR RESPIRATOR,
SUPPLIED AIR, OR SELF-CONTAINED BREATHING APPARATUS (SCBA) MUST BE
USED WHEN VAPOR CONCENTRATIONS EXCEED THE OCCUPATIONAL EXPOSURE
LIMITS.
Ventilation:USE ADEQUATE VENTILATION TO KEEP VAPOR CONCENTRATIONS OF
THIS MATERIAL BELOW THE OCCUPATIONAL EXPOSURE LIMITS.
Other Protective Equipment:OIL IMPERVIOUS INDUSTRIAL WORK CLOTHING TO
MINIMIZE SKIN CONTACT. EYE BATH AND SAFETY SHOWER RECOMMENDED.
Work Hygienic Practices:USE GOOD PERSONAL HYGIENE. USE WATERLESS HAND
CLEANER TO WASH EXPOSED SKIN. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
THE VARIABLE COMPOSITION MAKES IT IMPOSSIBLE TO SET A SPECIFIC EXPOSURE
LIMIT FOR ALL COMPOSITIONS OF THIS MATERIAL. SPECIFIC EXPOSURE
LIMITS FOR POTENTIAL COMPONENTS SUCH AS BENZENE SHOULD BE APPLIED
BASED ON AIR MONITORING TO ASSURE EMPLOYEES ARE NOT EXPOSED TO
EXCESSIVE VAPOR LEVELS OF COMPONENTS.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:80.0F,26.7C
Vapor Pres:400
Vapor Density:4
Spec Gravity:0.72
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:REDDISH GOLDEN BROWN LIQUID WITH GASOLINE ODOR.
Percent Volatiles by Volume:>95
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:BURNING OR EXCESSIVE HEATING MAY
PRODUCE CARBON MONOXIDE AND OTHER HARMFUL GASES/VAPORS.
==================== Disposal Considerations ====================
Waste Disposal Methods:IT IS THE RESPONSIBILITY OF THE USER TO
DETERMINE IF THE MATERIAL IS A HAZARDOUS WASTE AT THE TIME OF
DISPOSAL. CHECK BEFORE DISPOSING TO BE SURE YOU ARE IN COMPLIANCE
WITH ALL APPLICABLE LAWS AND REG ULATIONS. CHEMTREC/RCRA EMER.
NO.:800-424-9346
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:57 ATVR-U, TRANSFORMER OIL-UNINHIBITED
CAGE:LO811
CAGE:LO811
CAGE:2A267
============= Composition/Information on Ingredients =============
Ingred Name:ACID TREATED LIGHT NAPHTHENIC DISTILLATE; CAS #64742-19-4
CAS:64742-19-4
RTECS #:PY8033000
Fraction by Wt: 100%
ACGIH TLV:5MG/CUM(MIST)
===================== Hazards Identification =====================
Effects of Overexposure:EYES:MAY IRRITATE;SKIN:MILD IRRIT ON PROLONGED
CONTACT;INHAL:INGEST:EXCSSU MIST/LIQ IRRIT,DIARR,DIZZ
======================= First Aid Measures =======================
First Aid:SKIN:WASH W.SOAP & H*2O. EYES:FLUSH W. H*2O. INGESTED:DON'T
INDUCE VOMITING. INHALED:REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF
NEED. KEEP WARM & QUIET. REMOVE CONTAMINATED CLOTHING. NEVER GIVE
ANYTHING BY MOUTH TO UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:316F/158C (COC)
Extinguishing Media:CO*2, FOAM, DRY CHEM & H*2O FOG.
Fire Fighting Procedures:WEAR SELF-CNTD BRTHG,APP H*20 SPRAY TO COOL
CONTR.
Unusual Fire/Explosion Hazard:MAY IGNITE >200F & PRODUCE DENSE SMOKE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES,VENTILATE AREA
WELL.ABSORB WITH VERMICULITE OR OTHER MATERIALS, SUCH AS
SAWDUST,RAGS,PAPER & PLACE IN CLOSED CONTAINER. USE NON SPARKING
TOOLS. WEAR PROPER PROTECTIVE EQUIPMENT DURING CLEAN UP.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED,LOW
FIRE RISK AREA. PROTECT FROM PHYSICAL DAMAGE.KEEP CONTAINERS
CLOSED. MAINTAIN STANDARD HYGIENE FOR CHEM HANDLING
Other Precautions:AVOID CONTACT W/SKIN/CLOTHING.WASH HANDS THOROUGHLY
W/SOAP & WATER.LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE ONLY NIOSH APPROVED RESP WHEN NEEDED.
Ventilation:ADEQUATE FOR SPECIFIC EXPOSURE AND AREA OF USE.
Other Protective Equipment:USE CHEMICALLY RESISTANT NEOPRENE PLASTIC
Supplemental Safety and Health
MSDS FROM AMCMILLAN CO(ARKANSAS) DATED:10/28/85; SPEC REFERENCE:ASTM
D3487-82A, TYPE I; BASIC INGREDIENT PER DLSC-TIR:MINERAL OIL
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:580F,304C
Vapor Pres:<.1
Vapor Density:>1.0
Spec Gravity:0.90
Evaporation Rate & Reference:<1 (ETHER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS FLUID.MILD HYDROCARBON ODOR.
Percent Volatiles by Volume:NEG.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, IGNITION SOURCES
Hazardous Decomposition Products:INCOMPLETELY BURNED CARBON PRODUCTS,
CO*2, CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT FLUSH TO DRAIN/STORM SEWER;CONTRACT TO
AUTHORIZED DISPOSAL SERVICE.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:MANGANESE DIOXIDE,PURE,37-2872
Preparer's Name:ALEXANDER A. PICCIRILLI
CAGE:63759
CAGE:63759
============= Composition/Information on Ingredients =============
Ingred Name:MANGANESE DIOXIDE
CAS:1313-13-9
RTECS #:OP0350000
Fraction by Wt: 99%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG MN/M3 CEILING
ACGIH TLV:5 MG MN/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS UNKNOWN.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY
& GI TRACTS. ACUTE- WARNING! OXIDIZER. HARMFUL IF
SWALLOWED/INHALED. MAY CAUSE EYES IRRITATION & MECHANICAL INJURY.
PROLONGED/REPEATED SKIN CONTACT MAY CAUSE IRRI TATION. INHALATION
OF DUST/FUMES MAY CAUSE HUMAN TOXICITY. INGESTION MAY CAUSE
IRRITATION OF GI TRACT. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, EYE DAMAGE, WEAKNESS, SLEEPINESS,
EMOTIONAL DISTURBANCES, PARALYSIS
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION MAY BE
MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:CALL A DOCTOR IF SYMPTOMS PERSIST. EYE:IMMEDIATELY FLUSH WITH
WATER FOR 15 MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP &
WATER. INHALED:REMOVE TO FRESH AIR. PROVIDE CPR/OXYGEN IF NEEDED.
ORAL:I F CONSCIOUS, DRINK 1-2 GLASSES OF WATER& INDUCE VOMITING.
CALL A PHYSICIAN/POISON CONTROL CENTER IMMEDIATELY. NEVER GIVE
FLUID OR INDUCE VOMITING IF PATIENT IS UNCONSCIOUS OR HAS
CONVULSIONS.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE OR DRY CHEMICAL. USE
WATER SPRAY TO COOL FIRE EXPOSED CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:ABOVE 995F (535C) DECOMPOSES TO MN2O3 AND
OXYGEN WHICH INCREASES THE FLAMMABILITY OF ANY COMBUSTIBLE
SUBSTANCES.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP SPILL. AVOID CREATING DUST. PLACE
SPILL IN APPROPRIATE CONTAINER FOR RECYCLING OR WASTE DISPOSAL.
VENTILATE AREA AND WASH SPILL SITE WITH WATER. DO NOT FLUSH
CHEMICALS TO SEWER.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE AWAY FROM
OILS AND GREASE. KEEP CONTAINER TIGHTLY CLOSED. USE IN WELL
VENTILATED AREA.
Other Precautions:DO NOT RAISE DUST. AVOID CONTACT WITH EYES, SKIN OR
CLOTHING. AVOID INHALATION OF DUST. WASH THOROUGHLY AFTER HANDLING
MATERIAL. KEEP OUT OF REACH OF CHILDREN. DO NOT INGEST. FOR
LABORATORY USE ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. IF AIRBORNE
CONCENTRATION IS HIGH, WORK IN VENTILATION HOOD OR WEAR A
NIOSH-APPROVED DUST RESPIRATOR OR DUST MASK.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
FUME OR DUST LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER, PROTECTIVE
CLOTHING AND/OR UNIFORM
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:D1
NRC/State Lic Num:NOT RELEVANT
Melt/Freeze Pt:M.P/F.P Text:DECOMPOSES
Decomp Temp:Decomp Text:995F,535C
Spec Gravity:5.026
Viscosity:NOT RELEVANT
Evaporation Rate & Reference:NOT RELEVANT
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK/GRAYISH SILVERY METALLIC CRYSTALLINE
POWDER/GRANULES - NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CHLORATES, CHLORINE, TRIFLUORIDE, HYDROGEN PEROXIDE, SULFURIC ACID,
POTASSIUM AZIDE, RUBIDIUM, ETHYNYL & SODIUM PEROXIDE
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:OXYGEN, MN2O3, MANGANESE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. DISPOSE OF IN AN APPROVED LANDFILL OR
CONTRACT WITH A LICENSED WASTE DISPOSAL SERVICE.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:GF1700/9
CAGE:07294
CAGE:07294
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:MAY CAUSE IRRITATION TO EYES, NOSE, AND THROAT
AND A SKIN RASH MAY INJURE LIVER
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER IMMED. SKIN: WASH W/SOAP IMMED. INHALE
REMOVE TO FRESH AIR, RESPIR. AS NEEDED.INGEST:MEDICAL ATTN. GIVE
LARGE QTY OF WATER, INDUCE VOMITING, BUT DO NOT MAKE UNCONSCIOUS
PERSON VOMI T
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, DRY CHEMICAL,CARBON DIOXIDE
Fire Fighting Procedures:DO NOT USE WATER, WEAR RESPIRATOR AND
PROTECTIVE CLOTHING
Unusual Fire/Explosion Hazard:TOXIC GASES AND VAPORS I.E. HYDROGEN
CHLORIDE CARBON MONOXIDE
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. EVACUATE
UNPROTECTED PERSONS. STOP LEAK W/O RISK. WEAR SCBA & PROTECTIVE
CLOTHING. ABSORB LIQUID W/NONCOMB ABSORB. PLACE IN CLOSED CONTAINER
FOR DISPOSAL. VENTILATE AREA. D O NOT CONTAMINATE SEWER OR GROUND
WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL CONTACT. KEEP
CONTAINERS TIGHTLY CLOSED
Other Precautions:CHLORODIPHENYLS MAY ATTACK SOME TYPES OF RUBBER AND
PLASTIC.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA/MESA APPROVD SCBA
Ventilation:LOCAL EXHAUST TO MAINTN BELOW TLV.
Other Protective Equipment:WEAR FULL PROTECTIVE CLOTHING.
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS.CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE,THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:PALE YELLOW VISCOUS LIQUID W/HYDROCARBON ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURES,IGNITION SOURCES
Hazardous Decomposition Products:HYDROGEN CHLORIDE, CO, & OTHER
TOXIC/IRRITATING GASES/FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQD. GEN V.HIGH TEMP
INCINERATION. IN ACCORDANCE WITH ALL LOCAL, STATE, & FEDERAL
REGULATIONS. PERMITTED DISPOSAL OPERATOR REQUIRED.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:12991 CERTANIUM PMC SUPER QUICK SET
CAGE:61404
CAGE:61404
============= Composition/Information on Ingredients =============
Ingred Name:METHYL AMINO PHENOL
CAS:90-72-2
RTECS #:SN3500000
Minumum % Wt:1.
Maxumum % Wt:5.
Ingred Name:DIGLYCIDYL ETHER OF BISPHENOL A
CAS:25068-38-6
RTECS #:CE6880000
Minumum % Wt:5.
Maxumum % Wt:15.
Ingred Name:MERCAPTAN POLYMER
CAS:33007-83-9
Minumum % Wt:1.
Maxumum % Wt:20.
Ingred Name:MAGNESIUM SILICATE
CAS:14807-96-6
RTECS #:WW2710000
Minumum % Wt:20.
Maxumum % Wt:50.
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:2 MG/M3
Ingred Name:SILICA AMORPHOUS
CAS:7631-86-9
Minumum % Wt:10.
Maxumum % Wt:30.
Ingred Name:METAL ALLOY
Minumum % Wt:10.
Maxumum % Wt:25.
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 1100 MG/KG
Routes of Entry: Inhalation:UNKNOWN Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN:
SENSITIZATION/ALLERGIC RESPONSES. INHALATION: ANESTHETIC.
IRRITATION TO UPPER RESPIRATORY SYSTEM. INGESTION: HARMFUL. MAY BE
HARMFUL TO CNS.
Explanation of Carcinogenicity:NOT LISTED
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/PLENTY OF WATER FOR 15 MINS. SKIN:
WASH THOROUGHLY W/PLENTY OF WATER & SOAP. INHALATION: REMOVE TO
FRESH AIR. GIVE OXYGEN IF NEEDED. INGESTION: SHOW MSDS/LABEL.
INDUCE VOMITI NG.
===================== Fire Fighting Measures =====================
Flash Point:>93.3C, 200.F
Extinguishing Media:CO2, FOAM, DRY CHEMICALS, WATER SPRAY
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING EQUIPMENT.
Unusual Fire/Explosion Hazard:LOW BURNING RATE.
================== Accidental Release Measures ==================
UP W/ABSORBENT MATERIAL. CONTAIN & PICK UP WASTE MATERIALS, PUT IN
A SEALED APPROVED CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT & FLAME. KEEP IN A
COOL PLACE. KEEP OUT OF REACH OF CHILDREN. ALWAYS READ & FOLLOW
DIRECTIONS ON PRODUCT LABEL. FOR PROFESSIONAL & INDUSTRIAL USE
ONLY.
Other Precautions:USE ONLY IN WELL VENTILATED AREAS. AVOID CONTACT
W/EYES & SKIN. AVOID PROLONGED BREATHING OF VAPOR/SPRAY MIST. DON'T
TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROVED SELF CONTAINED BREATHING
APPARATUS.
Ventilation:LOCAL EXHAUST RECOMMENDED. MECHANICAL EXHAUST: REQUIRED.
Other Protective Equipment:PROTECTIVE CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE. WASH THOROUGHLY AFTER USING.
Supplemental Safety and Health
KEEP AWAY FROM FOOD, DRINK & ANIMAL FEEDS.
================== Physical/Chemical Properties ==================
Vapor Pres:NIL
Spec Gravity:2.2
Evaporation Rate & Reference:NONE
Solubility in Water:NONE
Appearance and Odor:PUTTY-MERCAPTAN ODOR
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS, AMINES
Stability Condition to Avoid:HEAT, FLAME
Hazardous Decomposition Products:CO, ALDEHYDES, ACIDS, AMINES, HYDROGEN
SULFIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:WCP-700 SERIES, FEDERAL TRAFFIC PAINT, (SUPDAT)
Preparer's Name:DAN DULAVA
CAGE:WC0LL
CAGE:WC0LL
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (CRYSTALLINE SILICA)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <11.05%
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: <19%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: <28%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:FORMALDEHYDE (SARA 302/313) (CERCLA)
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: TRACE
OSHA PEL:SEE 1910.1048
ACGIH TLV:C 0.3 PPM, A2
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:ETHYLENE OXIDE (SARA 302/313) (CERCLA)
CAS:75-21-8
RTECS #:KX2450000
Fraction by Wt: TRACE
OSHA PEL:1 PPM; SEE 1910.1047
ACGIH TLV:1 PPM, A2
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:ACETALDEHYDE (SARA 313) (CERCLA)
CAS:75-07-0
RTECS #:AB1925000
Fraction by Wt: TRACE
OSHA PEL:200 PPM
ACGIH TLV:C 25PPM, A3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VINYL CHLORIDE (SARA 313) (CERCLA)
CAS:75-01-4
RTECS #:KU9625000
Fraction by Wt: TRACE
OSHA PEL:SEE 1910.1017
ACGIH TLV:5 PPM, A1
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:VOLATILE ORGANIC COMPOUNDS LB/GAL:UNDER 250 (GRAM/LITER)
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:TRACE COMPONENT & RESIDUAL
MONOMER VAP MAY BE IRRIT TO EYES, SKIN, MUC MEMB, RESP TRACT, & MAY
PRDCE SYMP OF HDCH, NAUS IN POORLY VENTILATED AREAS. PRLNGD CONT
MAY CAUSE TRANSIENT REDDENING OF T HE SKIN. DIRECT EYE CONT MAY
CAUSE EYE IRRIT. THIS PROD CONTAINS CRYSTALLINE SILICA WHICH IS
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC MONO,
SUPP. VOL 7, PG 341, 1987:GROUP 2A. NTP 7TH ANNUAL RPT ON CARCINS,
1994: (SUPDAT)
Effects of Overexposure:HLTH HAZ:CONSIDERED A HAZ BY INHAL. CRYSTALLINE
SILICA HAS BEEN CLASSIFIED AS PROBABLY CARCIN FOR HUMANS BY IARC.
CRYSTALLINE SILICA IS ALSO A KNOWN CAUSE OF SILICOSIS. THIS PROD
CNTNS TRACE AMTS OF F ORMALDEHYDE, VINYL CHLORIDE & ACETALDEHYDE
WHICH ARE CONSIDERED CARCIN. TRACE AMTS OF ETHYLENE OXIDE MAY BE
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . EYES:IMMEDIATELY FLUSH
W/POTABLE WATER FOR MINIMUM OF 15 MINUTES, SEEK ASSISTANCE FROM MD
( ). SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD .
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . NON-FLAMMABLE. AFTER WATER EVAPORATES, REMAINING
MATERIAL WILL BURN.
Unusual Fire/Explosion Hazard:PRODUCT WILL NOT BURN BUT MAY SPATTER IF
TEMPERATURE EXCEEDS BOILING POINT OF WATER. DRIED SOLIDS CAN BURN
GIVING OFF OXIDES OF CARBON.
================== Accidental Release Measures ==================
Spill Release Procedures:STAY UPWIND AND AWAY FROM SPILL. IF SPILL IS
INDOORS, VENTILATE AREA OF SPILL. IF LARGE SPILL, CALL SPILL
RESPONSE TEAM. NOTIFY APPROPRIATE STATE/LOCAL AGENCIES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:ALWAYS PROTECT YOURSELF AND OTHER WHEN
USING THIS PRODUCT.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:MAINTAIN PROPER VENT IN WORKING AREA TO KEEP AIR
CONTAMINANT CONC BELOW OSHA PEL EXPOSURE LEVEL.
Other Protective Equipment:WEAR PROT CLTHG AS REQD TO PVNT SKIN
CONTACT. ANSI APPRVD EMER EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:WASH W/SOAP & WATER BEFORE EATING, DRINKING,
SMKNG/USING TOILET FACILITIES. LAUNDER CONTAMD CLTHG BEFORE REUSE.
Supplemental Safety and Health
MFR TRADE NAME/PART NO:YELLOW WATER BORNE. EXPLAN OF CARCIN:ANTIC TO BE
CARCIN. EFTS OF OVEREXP:PRESENT WHICH IS CARCIN & REPRO TOXIN.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>210F,>99C
Vapor Density:HVR/AIR
Spec Gravity:1.54
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:DILUTABLE
Appearance and Odor:OPAQUE LIQUID, MILD PAINT ODOR.
Percent Volatiles by Volume:48.72
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID MINERALS THAT REACT WITH WATER.
Stability Condition to Avoid:AVOID FREEZING.
Hazardous Decomposition Products:THERMAL DECOMPOSITION OR BURNING MAY
PRODUCE CARBON MONOXIDE AND CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF PRODUCT IN ACCORDANCE WITH LOCAL,
COUNTY, STATE AND FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:04-GLOSS BLACK
CAGE:NEWYO
CAGE:NEWYO
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTOXYETHANOL
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 1%
Other REC Limits:25 PPM
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
Ingred Name:SOLVENT NAPHTHA (LIGHT AROMATIC)
CAS:64742-95-6
Fraction by Wt: <1%
ACGIH TLV:100 PPM
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 6%
Other REC Limits:100 PPM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9293
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <1%
Other REC Limits:100 PPM
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYLENE CHLORIDE(SARA III)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 45%
Other REC Limits:A2 CARCINOGEN
OSHA PEL:500 PPM/C,1000; Z2
ACGIH TLV:50 PPM, A2; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: <35%
Other REC Limits:1000 PPM
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9192
Ingred Name:ISOBUTANE
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 35%
Other REC Limits:1000 PPM
OSHA PEL:1800 MG/CUM
Ingred Name:NAPHTA (PETROLEUM SPIRITS OR BENZIN)
CAS:8030-30-6
RTECS #:DE3030000
Fraction by Wt: 4%
Other REC Limits:STEL 400 PPM
OSHA PEL:100 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: LOSS OF COORDINATION &
EQUILIBRIUM, DIZZINESS, NAUSEA, HEADACHE. SKIN/EYE: IRRITATION.
Explanation of Carcinogenicity:METHYLENE CHLORIDE IS AN A2 CARCINOGEN
BY ACGIH
Effects of Overexposure:INHALATION: DIZZINESS, NAUSEA, HEADACHE.
SKIN/EYE: IRRITATION.
Medical Cond Aggravated by Exposure:INCREASES & SUSTAINS CARBOXY
HEMOGLOBIN LEVELS IN THE BLOOD, REDUCING OXYGEN CARRYING CAPACITY
IN THE BLOOD.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE ARTIFICIAL
RESPIRATION. KEEP QUIET/WARM. DON'T USE ADRENALIN. EYES: FLUSH
CONTACTED AREAS W/PLENTY OF WATER. IF PERSISTANT, GET MEDICAL
ATTENTION. SKIN: WASH W/S OAP & WATER. IF PERSISTANT GET MEDICAL
ATTENTION. INGESTION: DON'T GIVE ADRENALIN.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:156F
Lower Limits:1.8%
Upper Limits:9.5%
Extinguishing Media:12 B C EXTINGUISHER, CO2, FOAM.
Fire Fighting Procedures:STOP RELEASE OF MATERIALS IF POSSIBLE - COOL
STORAGE CONTAINER - AVOID ACCUMULATION OF UNBURNED MATERIAL -
EXCLUDE AIR.
Unusual Fire/Explosion Hazard:EXPANSION OF LIQUID/CHANGE OF STATE FROM
LIQUID TO VAPOR WILL ALLOW COMBUSTIBLE MIXTURE TO ENCOMPASS LARGE
AREA. VAPORS >AIR MAY TRAVEL TO AN IGNITION SOURCE.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE SOURCES OF IGNITION - ABSORB LIQUID
OR INERT MATERIAL SUCH AS SAND OR VERMICULITE. PLACE IN LEAK PROOF
CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID WATER CONTACT & HIGH
TEMPERATURES IN STORAGE.
Other Precautions:DO NOT PUNCTURE CANS. WEAR PROPER PROTECTIVE
CLOTHING, INCLUDING A NIOSH APPROVED SCBA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH APPROVED RESPIRATOR AS REQUIRED TO
PREVENT OVEREXPOSURE. USE AN ATMOSPHERE SUPPLYING RESPIRATOR FOR
ORGANIC VAPOR.
Ventilation:USE EXPLOSION PROOF VENTILATION TO CONTROL VAPOR
CONCENTRATION.
Other Protective Equipment:IMPERVIOUS CLOTHING
Work Hygienic Practices:WASH WITH SOAP & WATER AFTER EACH USE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:-44 TO +11F
Vapor Pres:70
Vapor Density:1.34
Spec Gravity:.85
Solubility in Water:MINIMAL
Appearance and Odor:BLACK LIQUID SOLVENT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:TEMPERATURES >120F. STORAGE NEAR OXIDIZING
MATERIAL. HEAT, SPARKS, OPEN FLAMES.
Hazardous Decomposition Products:CO, HYDROGEN CHLORIDE GAS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AS ORDINARY PAINT IN ACCORDANCE WITH
LOCAL & STATE REQUIREMENTS.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: HYVAC FLUSHING OIL, 93060
Cage: 0MJA2
Box: 389
=======================================================
Contractor Summary
=======================================================
Cage: 0MJA2
Box: 389
=======================================================
Ingredients
=======================================================
Cas: 64741-88-4
RTECS #: PY8040500
Percent by Wt: 100.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50: (ORAL, RAT): >15G/KG
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: INHALATION: LOW RISK OF INHALATION. IN ENCLOSED
SPACES OR WHEN HOT, VAPORS MAY REACH CONCENTRATIONS SUFFICIENT TO CAUSE
DROWSINESS, DIZZINESS, HEADACHE, NAUSEA OR LUNG IRRITATION. MISTS ABOVE T LV
MAY CAUSE CHEMICAL PNEUMONITIS. DERMAL: TRANSIENT, SLIGHT IRRITATION. EYE:
MAY BE MILDLY IRRITATING. INGESTION: GENERALLY LOW TOXICITY. VERY LARGE
AMOUNTS MAY CAUSE GENERALIZED DEPRESSION, HEADACHE , DROWSINESS, NAUSEA,
VOMITING OR DIARRHEA. SMALL DOSES MAY PRODUCE IRRITATION AND DIARRHEA.
CHRONIC: PROLONGED AND/OR FREQUENT CONTACT MAY CAUSE DRYING, CRACKING
(DERMATITIS) OR FOLLICULITIS. REPEATE D, EXCESSIVE EXPOSURE TO
(OVEREXPOSURE)
Explanation Of Carcinogenicity: PRODUCT LISTED AS CARCINOGEN OR POTENTIAL
CARCINOGEN BY: NTP: NO, IARC: NO,
OSHA: NO, OTHER: NO.
Signs And Symptions Of Overexposure: HEALTH HAZARDS ACUTE AND CHRONIC (CONT'D):
MISTS OR FUMES MAY INDUCE PULMONARY IRRITATION OR CHRONIC BRONCHITIS. OTHER
SPECIAL EFFECTS: NONE EXPECTED.
First Aid: INHALATION: REMOVE TO FRESH AIR. RESPIRATORY SUPPORT IF NECESSARY.
SEEK MEDICAL AID. DERMAL: WASH WITH SOAP, WATER. DO NOT WEAR HEAVILY
CONTAMINATED CLOTHING BEFORE LAUNDERING. EYES: FLUSH WITH LARGE VOLUMES OF
WATER. SEE PHYSICIAN IF ANY COMPLICATIONS ARISE. INGESTION: DO NOT INDUCE
VOMITING. SEEK MEDICAL AID. INJECTION: SUBCUTANEOUS INJECTION IS A MEDICAL
EMERGENCY. SEEK MEDICAL AID IMMEDIATELY. NOTES TO PHYSICIAN: FOLLOWING
INGESTION, AT A VISCOSITY OF ABOUT 350 SUS (100F), RISK OF ASPIRATION INTO
LUNGS IS REMOTE, BUT CUFFED TUBE LAVAGE IS STILL RECOMMENDED FOR LARGE
QUANTITIES. ASPIRATED M ATERIAL MAY CAUSE (TOXICOLOGICAL)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE SOURCES OF HEAT OR IGNITION, PROVIDE ADEQUATE
VENTILATION, CONTAIN THE LEAK. ABSORB SMALL SPILLS WITH SUITABLE MATERIAL
SUCH AS RAGS, STRAW OR SAND. REPORT SPILLS AS REQUIRED TO APPROPRIATE AUT
HORITIES.
Waste Disposal Methods: IT IS THE RESPONSIBILITY OF THE USER TO DETERMINE IF
MATERIAL IS HAZARDOUS WASTE AT TIME OF DISPOSAL. PLEASE CHECK BEFORE
DISPOSING OF PRODUCT OR CONTAINER TO BE SURE OF COMPLIANCE WITH ALL
APPLICABLE LAWS AND REGULATIONS. CONSULT APPROPRIATE FEDERAL, STATE AND
LOCAL AUTHORITIES BEFORE REUSING, REC ONDITIONING, RECLAIMING, RECYCLING OR
(TRANSPORT)
Handling And Storage Precautions: STORAGE: STORE BELOW 150F. DO NOT APPLY HIGH
HEAT OR FLAME TO CONTAINER. KEEP SEPARATE FROM STRONG OXIDIZING AGENTS.
CAUTION: EMPTY CONTAINERS MAY CONTAIN PRODUCT RESIDUE WHICH COULD INCLUDE
FLAMMABL E OR EXPLOSIVE VAPORS.
Other Precautions: PROTECTIVE MEASURES DURING REPAIR/MAINTENANCE OF
CONTAMINATED EQUIPMENT: SEE CONTROL MEASURES SECTION.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: COC
Flash Point: =215.6C, 420.F
Flash Point Text: SEE SUPP SAFETY
Lower Limits: ND
Upper Limits: ND
Extinguishing Media: CO*2, DRY CHEMICAL, FOAM OR WATER FOG.
Fire Fighting Procedures: A NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS
AND FULL PROTECTIVE EQUIPMENT (FP N). WEAR SELF-CONTAINED BREATHING GEAR WHEN
FIRE FIGHTING IN CONFINED SPACES.
Unusual Fire/Explosion Hazard: WATER MAY CAUSE FROTHING.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE NORMALLY REQUIRED. IF HIGH VAPOR OR MIST
CONCENTRATIONS EXPECTED, USE NIOSH RESPIRATOR APPROVED FOR ORGANIC VAPORS OR
MISTS. PERMITTED THRESHOLD AIR CONCENTRATIONS: OSHA, 1972, TWA: 5 MG/M3. OSHA
, 1985, PEL: 5 MG/M3. ACGIH, 1985-86, TWA: 5 MG/M3. ACGIH, 1985-86, STEL: 10
MG/M3.
Ventilation: VENTILATION IS REQUIRED WHEN WORKPLACE EXPOSURES EXCEED TLV.
EXPECTED.
Other Protective Equipment: EYEWASH AND DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA (FP N). WEAR BODY-COVERING WORK CLOTHES TO AVOID PROLONGED OR
REPEATED EXPOSURE.
Work Hygienic Practices: AVOID PROLONGED CONTACT WITH OIL; WASH SKIN THOROUGHLY
WITH SOAP AND WATER. LAUNDER SOILED WORK CLOTHES BEFORE REUSE.
Supplemental Safety and Health: FIRE AND EXPLOSION DATA (CON'T): FLASH POINT:
211C - 412 F (FLASH POINT METHOD: PM). FIRE POINT: 245C - 475F (FIRE POINT
METHOD: COC). NEFA: HEALTH-1, FLAMMABILITY-1, REACTIVITY-0.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: WIDE RANGE F @ 760 MMHG
M.P/F.P Text: NA
Vapor Pres: BELOW .0001@ MMHG (20C)
Vapor Density: 14 (AIR=1)
Spec Gravity: 0.87 (H2O=1)
PH: ND
Evaporation Rate & Reference: SEE OTHER INFORMATION
Solubility in Water: NEGLIGIBLE
Appearance and Odor: LIGHT AMBER LIQUID; LITTLE ODOR.
Percent Volatiles by Volume: NEGLIGIBLE
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE.
Materials To Avoid: STRONG OXIDANTS.
Hazardous Decomposition Products: THERMAL, UNLESS OTHERWISE SPECIFIED: CO,
CO*2.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NONE.
=======================================================
Toxicological Information
=======================================================
Toxicological Information: HAZARD DATA: ORAL: LD50 (RAT): >15G/KG. EYE:
PRACTICALLY NON-IRRITATING. SKIN: PRACTICALLY NON-IRRITATING. INHALATION:
LC50/4H(RAT): >5,000 MG/M3. TOXICITY SUMMARY: SLIGHTLY TOXIC, 1 PT. TO 1
QT. IS A PPROXIMATE LETHAL ORAL DOSE FOR 150 LBS. HUMAN ADULT. HEALTH HAZARD
CLASSIFICATION (PER 29 CFR PART 1910.1200): MUTAGEN: NO. HIGHLY TOXIC: NO.
TOXIC: NO. CORROSIVE: NO. IRRITANT: NO. SENSITIZER: N O. TERATOGEN: NO.
TARGET ORGAN: NO. FIRST AID (CONT'D): CHEMICAL PNEUMONITIS OR LIPOID
PNEUMONIA. SUBCUTANEOUS OR INTRAMUSCULAR INJECTION REQUIRES PROMPT SURGICAL
DEBRIDEMENT. IF NOT FAMILIAR WITH TECHNIQUE, SEEK SKILLED ADVICE.
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
Transport Information: HAZARDOUS MATERIAL PLACARD/LABEL: NONE. DOT INFORMATION:
DOT/UN SHIPPING NAME: PETROLEUM LUBRICATING OIL. DOT HAZARD CLASS:
NON-HAZARDOUS. DOT/UN HAZARD IDENTIFICATION #: NONE ASSIGNED. DOT SHIPPING C
ONTAINER RESTRICTIONS: NONE. DOT PLACARD: NONE. WASTE DISPOSAL (CON'T):
DISPOSING OF EMPTY CONTAINERS AND/OR WASTE RESIDUES OF THIS PRODUCT.
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: FAX: 610-792-0600. SYNONYMS: FLUSHING OIL. MATERIAL HAZARD
EVALUATION (PER OSHA'S HAZARD COMMUNICATION STANDARD 29 CFR PART 1910.100
(OHCS). HEALTH: NON-HAZARDOUS (OHCS). LABEL: NON-HAZARDOUS (OHCS).
PRECAUTIONARY STATEMENT: NONE. PHYSICAL/CHEMICAL DATA (CON'T): EVAPORATION
RATE: (ETHYL ETHER=1): 1,000 TIMES SLOWER. COMBUSTIBLE: NO. COMPRESSED GAS:
NO. EXPLOSIVE: NO. FLAMMABLE: NO. OXIDIZER:N O. REACTIVITY: NO. ORGANIC
PEROXIDE: NO. PYROPHORIC: NO. UNSTABLE: NO. STABLE: YES.
=======================================================
HAZCOM Label
=======================================================
Product ID: HYVAC FLUSHING OIL, 93060
Cage: 0MJA2
Company Name: HYVAC PRODUCTS INC
PO Box: 389
Zipcode: 19401-0389
Label Required IND: Y
Date Of Label Review: 09/26/2001
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE: INHALATION: LOW RISK OF INHAL. IN ENCLOSED
SPACES OR WHEN HOT, VAPORS MAY REACH CONCENTRATIONS SUFFICIENT TO CAUSE
DROWSINESS, DIZZINESS, HEADACHE, NAUSEA, LUNG IRRITATION. MISTS ABOVE TLV MAY
CAUSE CHEMICAL PNEUMONITIS. DERMAL: TRANSIENT, SLIGHT IRRIT. EYE: MAY BE
MILDLY IRRITATING. INGESTION: GENERALLY LOW TOXICITY. VERY LARGE AMOUNTS MAY
CAUSE GENERALIZED DEPRESSION, HEADACHE, DROWSINESS , NAUSEA, VOMIT, DIARRHEA.
SMALL DOSES MAY PRODUCE IRRIT & DIARRHEA. CHRONIC: PROLONGED &/OR
FREQUENT CONTACT MAY CAUSE DRYING, CRACKING (DERMATITIS), FOLLICULITIS.
REPEATED, EXCESS EXPOSURE TO MISTS MAY INDUCE PULMONARY IRRIT OR CHRONIC
BRONCHITIS.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:4782 COLD SET HEAT CURED
CAGE:GO219
CAGE:GO219
CAGE:97341
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <20%
Other REC Limits:375 MG/CUM
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BENZENE (HUMAN CARCINOGEN BY ACGIH, IARC, OSHA, NTP)
INTENDED CHANGE = IC
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: TRACE
Other REC Limits:16 MG/CUM
OSHA PEL:1 PPM (8 HR TWA)
ACGIH TLV:0.3 MG/CUM (A2)
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: <50%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HEAVY AROMATIC SOLVENT NAPHTHA PETROLEUM
CAS:64742-94-5
RTECS #:WF3100000
Fraction by Wt: <15%
OSHA PEL:100 PPM
ACGIH TLV:563 MG/CUM
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL (RAT) LD50: >5 G/KG (SEE SUPP)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION. SKIN: MILD
IRRITATION. INGESTION: MODERATELY TOXIC & MAY BE HARMFUL. MAY
PRODUCE VOMITING. ASPIRATION OF VOMITUS INTO LUNGS MUST BE AVOIDED
AS ASPIRATION PNEUMONITIS MAY OCCUR . INHALATION: IRRITATION TO
NOSE, THROAT, & RESPIRATORY TRACT.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:SKIN: DEFATTING & DRYING WHICH MAY RESULT IN
IRRITATION & DERMATITIS. INGESTION: CNS DEPRESSION. INHALATION: CNS
DEPRESSION, PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE,
BLOOD/LIVER/KIDNEY/EYE DAMAGE, ANE MIA OR GI TRACT PROBLEMS.
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/MILD SOAP & WATER. EYES: FLUSH W/WATER FOR AT
LEAST 15 MINS. INGESTION: GIVE 2 GLASSES OF WATER. DON'T INDUCE
VOMITING. ASPIRATION HAZARD. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS P ERSON. INHALATION: REMOVE TO FRESH AIR.IF BREATHING
IS DIFFICULT, ADMINISTER OXYGEN. IF BREATHING HAS STOPPED, GIVE
ARTIFICIAL RESPIRATION. KEEP WARM & QUIET. OBTAIN MEDICAL ATTENTION
IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:65-80F
Lower Limits:0.8%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG. DON'T USE
DIRECT STREAM OF WATER AS PRODUCT WILL FLOAT/REIGNITE ON SURFACE OF
WATER.
Fire Fighting Procedures:CLEAR FIRE AREA. DON'T ENTER CONFINED FIRE
SPACE W/OUT FULL BUNKER GEAR, INCLUDING POSITIVE PRESSURE SCBA.
COOL FIRE-EXPOSED CONTAINERS W/WATER.
Unusual Fire/Explosion Hazard:CONTAINERS EXPOSED TO INTENSE HEAT FROM
FIRES SHOULD BE COOLED W/WATER TO PREVENT VAPOR PRESSURE BUILD-UP
WHICH COULD RESULT IN CONTAINER RUPTURE. FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP PUBLIC AWAY. ELIMINATE SOURCES OF
IGNITION. PREVENT LIQUID FROM ENTERING LOW AREAS & WATERWAYS.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID STORING IN HIGH TEMPERATURE
AREAS OR NEAR FLAMES. FOR INDUSTRIAL USE ONLY, BY QUALIFIED/TRAINED
PERSONS. DON'T TAKE INTERNALLY.
Other Precautions:STORE RIGHT SIDE UP. KEEP OUT OF REACH OF CHILDREN.
INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING & INHALING THE
CONTENTS MAY BE HARMFUL OR FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF USE CONDITIONS GENERATE VAPORS/MISTS, USE
NIOSH APPROVED FULL FACEPIECE OR HALF MASK AIR PURIFYING CARTRIDGE
RESPIRATOR EQUIPPED FOR ORGANIC VAPOR/MISTS, A SCBA IN THE PRESSURE
DEMAND MODE, OR A SU PPLIED-AIR RESPIRATOR.
Ventilation:EXPLOSION PROOF DURING USE.
Other Protective Equipment:EYEWASH & SAFETY SHOWERS; HELMET W/FACE
SHIELD, BUNKER COATS, & RUBBER BOOTS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
LD50 INFORMATION IS FOR HIGH FLASH AROMATIC NAPHTHA.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:281-410F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:50-70
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG MINERAL ACIDS, OXIDANTS, ALKALI METALS, & HALOGENS
Stability Condition to Avoid:INTENSE HEAT, OPEN FLAME, & OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS & LAWS. FLAMMABLE LIQUID. UN 1263.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:GILLESPIE TUNG OIL FINISH HIGH GLOSS, PTV 6
CAGE:25451
CAGE:25451
============= Composition/Information on Ingredients =============
Ingred Name:TUNG OIL VARNISH.VP:2 MM @ 20C. (CONSISTS OF ING 2 & 3).
Fraction by Wt: <50%
Ingred Name:LIGROIN; (VM&P NAPHTHA). VP:2 MM @ 20C. (PERCENT:40% OF ING
1)
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: SEE ING
OSHA PEL:300 PPM;400 STEL
ACGIH TLV:300 PPM
Ingred Name:TUNG OIL. VP:<.1 MM @ 20C. (PERCENT:60% OF ING 1)
CAS:8001-20-5
Fraction by Wt: SEE ING
Ingred Name:AROMATIC PETROLEUM DISTILLATES; (MINERAL SPIRITS). VP:2 MM
@ 20C.
CAS:64741-41-9
Fraction by Wt: <55%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:MAY CAUSE NAUSEA AND
HEADACHE. SEVERE OVEREXPOSURE MAY CAUSE DEPRESSION OF CNS.
INGEST:HARMFUL OR FATAL IF SWALLOWED. MAY CAUSE NAUSEA, DIARRHEA
AND GI IRRITATION. SKIN:NONE EXPECTED. EYE: MAY CAUSE IRRITATION.
CHRONIC:MAY CAUSESKIN IRRITATION ON PROLONGED OR REPEATED CONTACT.
PROLONGED (EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:OR REPEATED CONTACT MAY CAUSE
DERMATITIS.
Medical Cond Aggravated by Exposure:NONE RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL:IF EXPERIENCING DIFFICULTY BREATHING, MOVE TO FRESH
AIR. ADMINISTER OXYGEN OR ARTIFICIAL RESPIRATION UNTIL MD
ASSISTANCE CAN BE RENDERED. INGEST:DO NOT INDUCE VOMITING. CALL
YOUR POISON CONTROL CENTER, HOSPITAL EMERGENCY ROOM OR MD
IMMEDIATELY. SKIN:WASH WITH SOAP AND WATER. EYE:FLUSH WITH LARGE
AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. IF IRRITATION PERSISTS,
GET MD ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:104F,40C
Lower Limits:0.8%
Extinguishing Media:CARBON DIOXIDE, DRY POWDER OR FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCAB/FULL PROT EQUIP
FOR FIRE FIGHTERS IN BLDGS/CONFINED AREAS. STORAGE CONTR EXPOSED TO
FIRE SHOULD BE KEPT COOL W/WATER (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CONTR TIGHTLY CLSD. CAUTION!
COMBUST. KEEP AWAY FROM HEAT, SPARKS, FLAME/ALL OTHER SOURCES OF
IGNIT. ALL OILY CLTH SHOULD BE SPREAD TO DRY IN AIRY (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID BREATHING VAPORS. VENT AREA. FLUSH LARGE
SPILLS INTO SUITABLE RETAINING AREA OR CONTAINERS WITH LARGE
AMOUNTS OF WATER. SMALL SPILLS CAN BE ABSORBED BY APPROPRIATE INERT
ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE NEAR FLAMES OR AT
ELEVATED TEMPERATURES.
Other Precautions:READ CAREFULLY ALL CAUTIONS AND DIRECTIONS ON PRODUCT
LABEL BEFORE USE. SINCE EMPTY CONTAINER RETAINS RESIDUE, FOLLOW ALL
LABEL WARNINGS EVEN AFTER CONTAINER IS EMPTY. DISPOSE OF EMPTY
CONTAINERS ACCO RDING TO LOC/STATE/FEDERAL REGULATIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR OSHA CONTROLLED WORK PLACE, USE ONLY W/ADEQ
VENT UNDER ENGINEERED CONTROL SYS DESIGNED TO PROVIDE MAX APPROP
TLV. FOR OCCAS USE WHERE ENGINEERED AIR CONTROL IS NOT FEASIBLE,
USE NIOSH/MSHA APPRVD RESP. FOR OCCAS CONSUMER USE,(SUPDAT)
Ventilation:ADEQUATE VENTILATION MUST BE PROVIDED. SEE RESPIRATORY
PROTECTION BELOW.
Other Protective Equipment:VARYING APPLICATION METHODS CAN DICTATE USE
OF ADDITIONAL PROT SAFETY EQUIP, SUCH AS IMPERMEABLE APRONS, ETC.
Work Hygienic Practices:WASH HANDS THORO AFTER USE. BEFORE REUSE, THORO
CLEAN ANY CLOTHING OR PROT EQUIP WHICH HAS BEEN CONTAM BY PRIOR
USE.
Supplemental Safety and Health
FIRE FIGHT PROC:SPRAY TO PREVENT PRESSURE BUILD-UP. EXPLOS HAZ:SPOT OR
DESTROYED AT ONCE. THEY ARE SUBJECT TO SPONTANEOUS COMBUSTION, AND
UNDER CERTAIN CONDITIONS, CAN CAUSE FIRES.RESP PROT:USE ONLY W ITH
ADEQUATE VENTILATION.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>318F,>159C
Vapor Pres:SEE ING
Vapor Density:HVR/AIR
Spec Gravity:0.821
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:73.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CO, CO*2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL,
STATE AND FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CONATHANE EN-1554 PART B CURATIVE
Preparer's Name:HENRY SIMMONS
CAGE:6X798
CAGE:6X798
============= Composition/Information on Ingredients =============
Ingred Name:4,4'-METHYLENEBIS.(.2-CHLOROANILINE.).
CAS:101-14-4
RTECS #:CY1050000
Minumum % Wt:24.
Maxumum % Wt:34.
ACGIH TLV:0.11 MG/M3;0.01 PPM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:CAUSES EYE AND SKIN IRRITATION.
CONTAINS MATERIALS WHICH CAUSED CANCER IN LABORATORY ANIMAL TESTS.
RISK OF CANCER DEPENDS ON DURATION AND LEVEL ON EXPOSURE.
Effects of Overexposure:ACUTE ORAL (RAT) AND DERMAL (RABBIT) ARE BOTH
ESTIMATED TO BE GREATER THAN 2,000 MG/KG. THE 4-HOUR INHALATION
(RAT) IS ESTIMATED TO BE GREATER THAN 20 MG/L. DIRECT CONTACT WITH
THIS MATERIAL MAY CAUS E MODERATE EYE AND SKIN IRRITATION.
======================= First Aid Measures =======================
First Aid:IN CASE OF SKIN CONTACT. REMOVE CONTAMINATED CLOTHING WITHOUT
DELAY. FLUSH SKIN THOROUGHLY WITH WATER. DO NOT REUSE CLOTHING
WITHOUT LAUNDERING. IN CASE OF EYE CONTACT, IMMEDIATELY IRRIGATE
WITH PLENT Y OF 15 MINUTES. OBTAIN MEDICAL ATTENTION IF IRRITATION
PERSISTS.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>100.C, 212.F
Extinguishing Media:USE WATER SPRAY, CARBON DIOXIDE OR DRY CHEMICAL TO
EXTINGUISH FIRES. USE WATER TO KEEP CONTAINERS COOL.
================== Accidental Release Measures ==================
Spill Release Procedures:WHERE EXPOSURE LEVEL IS NOT KNOWN, WEAR NIOSH
APPROVED, POSITIVE PRESSURE, SELF CONTAINED RESPIRATOR. WHERE
EXPOSURE LEVEL IS KNOWN. WEAR NIOSH APPROVED RESPIRATOR SUITABLE
FOR LEVEL OF EXPOSURE. IN A DDITION TO THE PROTECTIVE
CLOTHING/EQUIPMENT IN SECTION 8 (EXPOSURE CONTROLS/PERSONAL
PROTECTION), WEAR IMPERVIOUS BOOTS. COVER SPILLS WITH SOME INERT
ABSORBENT MATERIALS.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH EYES, SKIN, AND
CLOTHING. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE EXPOSURES EXCEED THE PEL, USE RESPIRATOR
APPROVED BY NIOSH FOR THE MATERIALS
Ventilation:WHERE THIS MATERIAL IS NOT USED IN A CLOSED SYSTEM, GOOD
ENCLOSURE AND EXHAUST VENTILATION SHOULD BE PROVIDED TO CONTROL
EXPOSURES
Other Protective Equipment:PROTECTIVE CLOTHING SUCH AS IMPERVIOUS
COVERALLS ARE RECOMMENDED TO PREVENT SKIN CONTACT.
Work Hygienic Practices:EYEWASH EQUIPMENT AND SAFETY SHOWER SHOULD BE
PROVIDED IN AREAS OF POTENTIAL EXPOSURES.
Supplemental Safety and Health
BEFORE EATING, DRINKING, OR SMOKING, WASH FACE AND HANDS WITH SOAP AND
WATER.
================== Physical/Chemical Properties ==================
Vapor Density:NEGLIGIBLE
Spec Gravity:1.10
Appearance and Odor:LIGHT AMBER MEDIUM VISCOSITY LIQUID; MILD
CHARACTERISTIC ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACID OR BASE AND ALSO OXIDIZING AGENTS.
Stability Condition to Avoid:REACTS WITH ISOCYANATES TO FORM HIGH
MOLECULAR WEIGHT POLYMER
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE;
OXIDES OF NITROGEN.
=================== Toxicological Information===================
Toxicological Information:4,4'-METHYLENEBIS-(2-CHLOROANLLINE) (MOCA)
HAS ACUTE ORAL LD50 VALUES OF 2.1 G/KG IN RATS AND 0.88 G/KG IN
MICE. EYE AND SKIN EXPOSURE HAS RESULTED IN INFLAMMATION AND
IRRITATION. THIS MATERIAL DID NO T PRODUCE ALLERGIC CONTRACT
DERMATITIS IN GUINEA PIGS. MOCA IS MUTAGENIC/GENOTOXIC IN A VARIETY
OF IN VITRO AND VIVO ASSAYS. MOCA WAS CARCINOGENIC IN MICE, RATS,
AND DOGS. MICE FED THIS MATERIAL 0.1 A ND 0.2% IN THEIR DIETS WERE
OBSERVED WITH VASCULAR TUMORS IN THE MALES AT BOTH DOES AND IN THE
FEMALES AT THE HIGH DOSE. LIVER TUMORS WERE OBSERVED IN BOTH GROUPS
OF FEMALE MICE. IN ANOTHER STUDY, LIV ER TUMORS WERE OBSERVED IN
FEMALE RICE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE MADE IN ACCORDANCE WITH
APPLICABLE REGULATIONS.
===================== Regulatory Information =====================
SARA Title III Information:THE FOLLOWING COMPONENTS ARE DEFINED A TOXIC
CHEMICALS OF SECTION 313 OF TITLE III AND 40 CFR OR SUBJECT TO
OTHER EPA REGULATIONS. 4,4?-METHYLENEBIS-(2-CHLOROANILINE)(MOCA)
101-14-424-34% U158 (R CRA)
Federal Regulatory Information:US TSCA: THIS PRODUCT IS MANUFACTURED IN
COMPLIANCE WITH ALL PROVISIONS OF THE TOXIC SUBSTANCES CONTROL ACT,
15 U.S.C. 2601 ET. SEQ
State Regulatory Information:
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:DEX-O-TEX TERRAZZO M UNDERLAYMENT AGGREGATE
CAGE:88167
CAGE:88167
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:PUMICE
CAS:13220-90-8
OSHA PEL:10 MG/M3 TDUST (MFR)
ACGIH TLV:10 MG/M3 TDUST (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE IRRITATION. CHRONIC:FREE
SILICA DUST MAY CAUSE DELAYED LUNG INJURY.
Explanation of Carcinogenicity:CRYSTALLINE SILICA: GROUP 2A (IARC)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NOT KNOWN.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE SUBJECT TO FRESH AIR IF NEEDED. EYES: FLUSH WITH
WATER FOR AT LEAST 15 MIN. SKIN:WASH WITH SOAP AND WATER. INGEST:
CALL PHYS.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP OR VACUUM USING GOOD VENTILATION SO TLV
IS NOT EXCEEDED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE DUSTLESS SYSTEMS FOR HANDLING,
STORAGE, AND CLEAN UP SO TLV OF SIO2 IS NOT EXCEEDED-STORE IN DRY
AREA.
Other Precautions:PRACTICE GOOD HOUSEKEEPING AND POST WORK AREAS WHERE
PRODUCT IS USED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:LOCAL EXHAUST/MECHANICAL(GEN): FOLLOW OSHA STANDARD.
Other Protective Equipment:AS NEEDED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRANULAR POWDER-NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
DISSOLVED BY HYDROFLUORIC ACID WHICH CAN RESULT IN SILICON
TETRAFLUORIDE (SIF4) WHICH IS CORROSIVE GAS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN SANITARY LANDFILL IN ACCORDANCE WITH
STATE, LOCAL AND FEDERAL REGULATIONS ON SOLID WASTES.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:4CS250R,Y621,Y398A ELECTRON TUBE
CAGE:06980
CAGE:06980
============= Composition/Information on Ingredients =============
Ingred Name:BERYLLIUM OXIDE (AS BERYLLIUM)
CAS:1304-56-9
RTECS #:DS4025000
Fraction by Wt: 20%.
OSHA PEL:0.002 MG/M3; C,0.005
ACGIH TLV:0.002 MG/M3; A2;8990
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:CHRONIC:INHAL OF EXCESSIVE AMOUNTS OF
"RESPIRABLE" BERYLLIUM MAY CAUSE SERIOUS,CHRONIC PULMONARY ILLNESS.
Explanation of Carcinogenicity:BERYLLIUM(+ COMPOUNDS)(7440-41-7)
Effects of Overexposure:INHAL: COUGH, CHEST PAIN, DYSPNEA, ANOREXIA &
WEIGHT LOSS, FATIGUE.
======================= First Aid Measures =======================
First Aid:EYE: IRRIGATE ACUTE EXPOSURES-NORMAL CARE FOR CONJUNCTIVITIS
& CORNEAL ULCERATIONS; SKIN: WASH CONTAMINATED AREAS OF BODY W/SOAP
& WATER. TREAT BURNS IN USUAL MANNER. DERMATITIS: REMOVE FROM
EXPOSURE; PULMONARY BERYLLIOSIS: HOSPITALIZATION, ANTIBIOTICS,
ANTIHISTAMINES, CORTISONE, GENERAL SUPPORT.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NON-COMBUSTIBLE; USE MEDIA APPROPRIATE FOR
SURROUNDING FIRE.
Fire Fighting Procedures:NONE CITED!
Unusual Fire/Explosion Hazard:MATERIAL IS NON-FLAMMABLE
================== Accidental Release Measures ==================
Spill Release Procedures:IF CERAMIC IS BROKEN, HANDLE AS HAZARDOUS.
CLEAN UP SPILLS PROMPTLY BY VACUUM OR WET CLEANING METHODS TO AVOID
GENERATING DUST. WEAR APPROVED RESPIRATORY PROTECTIVE EQUIPMENT.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE TUBE W/CARE TO AVOID BREAKING
OR DAMAGE.
Other Precautions:AVOID THE GENERATION OF HAZARDOUS DUST OR FUMES
PRODUCED BY MACHINING, FILLING, WELDING, GRINDING OR CHEMICAL
ETCHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED DURING NORMAL USE OF PRODUCT; AT
ANY DETECTABLE CONCENTRATE(DUST OR FUME) ANY SELF-CONTAINED
BREATHING APPARATUS W/FULL FACEPIECE & OPERATED IN A PRESSURE
DEMAND OR OTHER POSITIVE PRESSU RE MODE.
Ventilation:NORMAL ROOM VENTILATION.
Other Protective Equipment:NONE REQUIRED DURING NORMAL USE
Work Hygienic Practices:AVOID THE GENERATION OF HAZARDOUS DUST OR
FUMES.
Supplemental Safety and Health
KEY1:N1.
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:ELECTRON TUBE W/ A CERAMIC & METAL OR GLASS
ENVELOPE MATERIAL.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BERYLLIUM OXIDE REACTS W/WATER VAPOR AT ABOUT 2200F/1204C TO FORM
VOLATILE BERYLLIUM HYDROXIDE.
Hazardous Decomposition Products:BERYLLIUM HYDROXIDE IN THE PRESENCE OF
WATER VAPOR AT 2200F/1204C.
==================== Disposal Considerations ====================
Waste Disposal Methods:SOLID MATERIAL SHOULD BE TAKEN TO CLASS I
DISPOSAL SITE.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:S151 BRIGHT YELLOW
CAGE:DO642
CAGE:DO642
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 18-23%
OSHA PEL:2400 MG/CUM
ACGIH TLV:750 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 18-20%
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:PROPYLENEGLYCOL MONOMETHYL ETHER ACETATE,
1-METHOXY-2-PROPANOL ACETATE
CAS:108-65-6
RTECS #:AI8925000
Fraction by Wt: 8%
Ingred Name:HEXANE, N-HEXANE
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: 14-22%
Other REC Limits:50 PPM
OSHA PEL:1800 MG/CUM
ACGIH TLV:176 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:V M & P NAPHTHA, LIGROINE, MINERAL SPIRITS
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 15-25%
Other REC Limits:STEL 400 PPM
ACGIH TLV:300 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NERVOUS SYSTEM DEPRESSION,
POSSIBLE UNCONSCIOUSNESS EVEN ASPHYXIATION, RESPIRATORY TRACT
IRRITATION. EYES: IRRITATION. SKIN: IRRITATION, ABSORPTION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: HEADACHE, NAUSEA, VOMITING,
DROWSINESS, CYANOSIS, RESPIRATORY DISTRESS, UNCONSCIOUSNESS,
ASPHYXIA.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS.
INGESTION: IF ACCIDENTLY SWALLOWED, DILUTE BY DRINKING LARGE
QUANTITIES OF WATER. INHALATION: REMOVE TO FRESH AIR. IF NOT
BREATHING, GIVE ARTIF ICIAL RESPIRATION, PREFERABLY MOUTH-TO-MOUTH.
IF BREATHING IS DIFFICULT, GIVE OXYGEN. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL, FOAM, OR CO2
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE. USE WATER TO KEEP
FIRE-EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:EXTREMELY FLAMMABLE. CONTENTS UNDER
PRESSURE. EXPOSURE TO HIGH TEMPERATURE MAY CAUSE BURSTING. DON'T
SPRAY NEAR OPEN FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. SOAK UP
W/INERT ABSORBENT MATERIAL & REMOVE TO A CHEMICAL DISPOSAL AREA.
PREVENT ENTRY INTO NATURAL BODIES OF WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE AT TEMPS >120F. AVOID
RADIATORS, STOVES, DIRECT SUNLIGHT OR OTHER HEAT SOURCE. USE
W/ADEQUATE VENTILATION.
Other Precautions:AVOID CONTACT W/SKIN, EYES & BREATHING OF VAPOR OR
MIST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE AIR CONTAMINANTS CAN EXCEED, USE A
NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE LOCAL EXHAUST, ENCLOSED SYSTEM DESIGN, PROCESS
ISOLATION & REMOVE CONTROL IN COMBINATION W/PROTECTIVE EQUIPMENT.
Work Hygienic Practices:GOOD INDUSTRIAL HYGIENE & SAFETY PRACTICES.
WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Pres: 60 PSIG
Vapor Density:>1
Spec Gravity:<1
Evaporation Rate & Reference:FASTER THAN BU AC
Solubility in Water:SLIGHT
Percent Volatiles by Volume: 84/WT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:DIRECT SUNLIGHT, HIGH TEMPS OR OTHER HEAT
SOURCE.
Hazardous Decomposition Products:OXIDES OF CARBON
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. EMPTY CONTAINER, MAY CONTAIN EXPLOSIVE VAPORS;
DON'T CUT, PUNCTURE OR WELD ON OR NEARBY. INCINERATION WILL CAUSE
CONTAINER TO BURST VIOL ENTLY.
| 1 |
gloves_mandatory
|
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.