text
stringlengths 542
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:TRIAMCINALONE ACETONIDE 0.1% CR./OINT
CAGE:61069
CAGE:61069
============= Composition/Information on Ingredients =============
Ingred Name:NON HAZARDOUS INGREDIENTS
Fraction by Wt: BALANCE
Other REC Limits:NONE RECOMMENDED
Ingred Name:TRIAMINOLONE ACETONIDE
CAS:638-68-6
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) 6300 MG/KG
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ELEVATED BLOOD PRESSURE, ELECTROLYTE
IMBALANCES DUE TO SODIUM/FLUID RETENTION. CHRONIC OVEREXPOSURE MAY
RESULT IN PITUITARY-ADRENAL SUPPRESSION INCLUDING FLUID RETENTION,
CUSHING'S SYNDROME, HYPERGLYC EMIA, GLYCOSURIA, INCREASED
SUSCEPTIBILITY TO INFECTION, PEPTIC ULCERS, OSTEOPOROSIS, WEAKNESS
IN ARMS AND LEGS
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:IT MAY ENHANCE ACTIVE OR REACTIVATE
LATENT TUBERCULOSIS, AND ENHANCE SECONDARY EYE INFECTIONS DUE TO
FUNGI OR VIRUSES.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP
WARM AND QUIET. GET MEDICAL ATTENTION. SKIN: WASH AFFECTED AREA
THOROUGHLY WITH SOAP AND WATER. IF IRRITATION PERSISTS, GET MEDICAL
ATTENTION.EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR 15 MINUTES.
GET MEDICAL ATTENTION. INGESTION: CONTACT A PHYSICIAN OR POISON
CONTROL CENTER.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:NONFLAMMABLE. USE MEDIA SUITABLE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM WITH HEPA FILTERED EQUIPMENT OR SCOOP
SPILLED MATERIAL AND PLACE IN CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:WEAR DUST RESPIRATOR AND RUBBER
SWALLOWED, INHALED OR ABSORBED THROUGH THE SKIN.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXOSURES BELOW PEL (TLV), USE NIOSH/MSHA APPROVED RESPIRATOR AS PER
CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS AND NIOSH RESPIRATOR
SELECTION.
Ventilation:LOCAL EXHAUST RECOMMENDED
Other Protective Equipment:COVERING FOR EXPOSED SKIN.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NOT GIVEN
Melt/Freeze Pt:M.P/F.P Text:558F,292C
Vapor Pres:NOT GIVEN
Vapor Density:NOT GIVEN
Spec Gravity:NOT GIVEN
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:SLIGHT
Appearance and Odor:WHITE CREAM, MILD CHARACTERISTIC ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:DRUM BRAKE SEGMENTS & BLOCKS(SEE SUPP DATA)
Preparer's Name:E.L. ROGERS
CAGE:OLYW2
CAGE:OLYW2
CAGE:76126
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9293
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:SILICATE(S)
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192
Ingred Name:COKE (PETROLEUM DERIVED)
Other REC Limits:NONE RECOMENDED
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
Ingred Name:RESIN
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:GRAPHITE, SYNTHETIC
CAS:7440-44-0
RTECS #:FF5250100
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9293
Ingred Name:IRON, ZINC, ALUMINUM & THEIR OXIDES
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3 RDUST
ACGIH TLV:10 MG/M3 RDUST
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INDIVIDUAL SENSITIVITY TO PARTIALLY
CURED PHENOLIC OR CASHEW RESINS MAY CAUSE DERMATITIS-TYPE
REACTIONS. DUSTS OF CRYSTALLINE SILICA MAY PRODUCE SILICOSIS. METAL
DUSTS CAN BE EYE/UPPER RESPIRATORY SYS TEM IRRITANTS. INHALATION OF
AIRBORNE ASBESTOS FIBER > "OSHA PEL" MAY BE A HEALTH HAZARD & CAUSE
ASBESTOSIS, LUNG CANCER
Explanation of Carcinogenicity:INHAL.OF AIRBORNE ASBESTOSIS > "OSHA
PEL" MAY CAUSE ASBESTOSIS, LUNG CANCER, OR MESOTHELIOMA MANIFESTED
YEARS AFTR EXPO
Effects of Overexposure:PARTIALLY CURED CASHEW RESINS: SKIN ERUPTIONS
SIMILIAR IN APPEARANCE TO POISON IVY; LUNG EFFECTS FROM ASBESTOS &
CRYSTALLINE SILICA: COUGHING, WHEEZING, BREATH SHORTNESS, IMPAIRED
PULMONARY FUNCTION; EYES: DUST MAY CAUSE IRRITATION; INGEST:
GASTROINTESTINAL DISTURBANCES POSSIBLE FROM INGESTION.
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY AILMENTS
OR PRIOR SKIN SENSITIZATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT,
GIVE OXYGEN. GET MEDICAL ATTENTION. EYE: FLUSH WITH RUNNING WATER
FOR 15 MINUTES WHILE LIFTING EYELIDS. GET MEDICAL ATTENTION. SKIN:
WASH WI TH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NONCOMBUSTIBLE. USE EXTINGUISHING MEDIA APPROPRIATE
FOR SURROUNDING FIRE CONDITIONS.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED
WITH AN OUTLET "HEPA" FILTER TO PREVENT RE-INTRODUCTION OF ASBESTOS
FIBERS TO THE ENVIRONM ENT.
======================Handling and Storage ======================
Handling and Storage Precautions:THE FRICTION MATERIAL PRODUCT, AS
SHIPPED, IS NOT CONSIDERED HAZARDOUS, BUT MACHINING(GRINDING,
DRILLINGS, ETC.) & NORMAL USE MAY CREATE DUST/FIBERS.
Other Precautions:WORK ENVIRONMENT SHOULD BE MONITORED TO DETERMINE IF
EMPLOYEE EXPOSURE EXCEEDS OSHA'S PEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER NORMAL CONDITIONS. HOWEVER,
IF AIRBORNE ASBESTOS FIBERS CONCENTRATION IS IN EXCESS OF THE OSHA
PEL, NIOSH APPROVED RESPIRATORS FOR ASBESTOS SHOULD BE USED!!
REVIEW OSHA'S ASBESTOS R EG(29CFR1910.1001)
Ventilation:LOCAL EXHAUST PREFERRED ESPECIALLY DURING MACHINING
INCLUDING GRINDING & DRILLING.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND TO MINIMIZE
EXPOSURE TO ASBESTOS FIBERS/DUST. CONSULT LOCAL INDUSTRIAL
HYGIENIST.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING, DRINKING OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
REVIEW THE "FRICTION MATERIALS STANDARDS INSTITUTE'S RECOMMENDED
PROCEDURES FOR REDUCING ASBESTOS DUST DURING BRAKE SERVICING".
CHECK WITH LOCAL INDUSTRIAL HYGIENST FOR APPROPRIATE OPERATING
PROCEDURE S! P/N INFORMATION: KALMAR P/N 4873421 OR 74873421-7;
PROFILE GEAR P/N: 726456-1
================== Physical/Chemical Properties ==================
HCC:T6
Spec Gravity:1.3 TO 3.7
Evaporation Rate & Reference:0
Solubility in Water:NEGLIGIBLE
Appearance and Odor:SOLID, ODORLESS. LIGHT TAN TO DARK GRAY COLOR.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
Hazardous Decomposition Products:INCOMPLETE COMBUSTION WILL CREATE
CARBON MONOXIDE & CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN PROPER RECEPTACLES APPROPRIATELY
LABELED IN ACCORDANCE WITH APPLICABLE FEDERAL, STATE, & LOCAL
REGULATIONS. PLACE RECEPTACLES IN AN "AUTHORIZED LANDFILL" AS
DESIGNATED BY FEDERAL OR STAT E AUTHORITIES.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:SUPER UNLEADED GASOLINE/PREMIUM UNLEADED GA
CAGE:46845
CAGE:46845
============= Composition/Information on Ingredients =============
Ingred Name:HYDROCARBONS
Fraction by Wt: >50%
Other REC Limits:NONE RECOMMENDED
Ingred Name:BENZENE (SARA III)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: .1-4.9%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1PPM/5STEL;1910.1028
ACGIH TLV:10 PPM; A2; 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:ETHYL BENZENE (SARA III)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM/125 STEL
ACGIH TLV:100 PPM/125STEL 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:CUMENE (SARA III)
CAS:98-82-8
RTECS #:GR8575000
Fraction by Wt: 1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:1,2,4-TRIMETHYLBENZENE (SARA III)
CAS:95-63-6
RTECS #:DC3325000
Fraction by Wt: 2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:25 PPM
ACGIH TLV:25 PPM; 9293
Ingred Name:METHYL TERT-BUTYL ETHER (SARA III)
CAS:1634-04-4
RTECS #:KN5250000
Fraction by Wt: <15%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 12%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:THE PRODUCT CONTAINS PETROLEUM
HYDROCARBON, & AS WITH MANY PETROLEUM PRODUCTS, IT MAY CAUSE
IRRITATION TO THE EYES, SKIN & LUNGS AFTER PROLONGED OR REPEATED
EXPOSURE. A FEW STUDIES HAVE INDICATED THAT WORKERS EXPOSED MANY
YEARS TO HIGH CONCENTRATIONS OF BENZENE HAVE A SLIGHTLY HIGHER
INCIDENCE OF LEUKEMIA.
Explanation of Carcinogenicity:BENZENE IS A KNOWN HUMAN CARCINOGEN.
Effects of Overexposure:OVEREXPOSURE MAY CAUSE WEAKNESS, HEADACHE,
NAUSEA, CONFUSION, BLURRED VISION, DROWSINESS AND OTHER NERVOUS
SYSTEM EFFECTS; GREATER EXPOSURE MAY CAUSE DIZZINESS, SLURRED
SPEECH, FLUSHED FACE, UNCONSCIO USNESS OR CONVULSION. BENZENE CAN
ALSO BE TOXIC TO THE BLOOD AND BLOOD-FORMING TISSUES.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT
LEAST 15 MIN. CALL A PHYSICIAN. SKIN: IMMEDIATELY WASH SKIN WITH
SOAP AND WATER. IF IRRITATION DEVELOPS, GET MEDICAL HELP.
INHALATION: REMOVE T O FRESH AIR. IF NOT BREATHING, PERFORM CPR. IF
HARD TO BREATH, GIVE OXYGEN. CALL PHYSICIAN. INGESTION: DO NOT
INDUCE VOMITING. GIVE LARGE QUANTITIES OF WATER. CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-50F,-46C
Autoignition Temp:Autoignition Temp Text:536F
Lower Limits:<1
Upper Limits:8
Extinguishing Media:USE DRY CHEMICAL, CARBON DIOXIDE, FOAM. WATER MAY
BE INEFFECTIVE TO EXTINGUISH, USE WATER TO COOL FIRE EXPOSED
CONTAINER
Fire Fighting Procedures:IF LEAK/SPILL HAS NOT IGNITED, USE WATER SPRAY
TO DISPERSE THE VAPORS & TO PROTECT PERSONNEL ATTEMPTING TO STOP
LEAK. USE WATER SPRAY TO FLUSH SPILL FROM AREA.
Unusual Fire/Explosion Hazard:HIGHLY FLAMMABLE. DO NOT ENTER
ENCLOSED/CONFINED SPACE WITHOUT PROPER PROTECTIVE EQUIPMENT
INCLUDING RESPIRATORY PROTECTION. FUMES OF CARBON MONOXIDE &
DIOXIDE.
================== Accidental Release Measures ==================
Spill Release Procedures:THIS MATERIAL IS FLAMMABLE. CONTAIN SPILL.
RECOVER AS MUCH OF PRODUCT AS POSSIBLE. NONRECOVERABLE PRODUCT,
CONTAMINATED SOIL, DEBRIS & OTHER MATERIAL SHOULD BE PLACED IN
PROPER CONTAINERS FOR ULTIMATE DISPOSAL. AVOID WMATERIAL ENTERING
SEWERS.
Neutralizing Agent:NA
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN ACCORDANCE WITH NATIONAL FIRE
PROTECTION ASSOCIATION REGULATIONS.
Other Precautions:NOTES TO PHYSICIAN: GASTRIC LAVAGE BY QUALIFIED
MEDICAL PERSONNEL MAY BE CONSIDERED, DEPENDING ON QUANTITY OF
MATERIAL INGESTED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELECT APPROPIATE NIOSH-APPROVED RESPIRATORY
PROTECTION WHERE NECESSARY TO MAINTAIN EXPOSURE BELOW THE
APPLICABLE LIMITS.
Ventilation:USE SUFFICIENT VENTILATION TO MAINTAIN ATMOSPHERIC
CONCENTRATIONS BELOW PERMISSIBLE EXPOSURE LIMITS.
Other Protective Equipment:SUFFICIENT PROTECTIVE CLOTHING TO MINIMIZE
SKIN EXPOSURE. L
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING, DRINKING OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
AVOID CONTACT WITH EYES, SKIN, OR CLOTHING.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:85.0F,29.4C
Melt/Freeze Pt:M.P/F.P Text:NA
Decomp Temp:Decomp Text:NA
Vapor Pres:275-475
Vapor Density:>1 AIR=1
Spec Gravity:0.70-.77
pH:NA
Viscosity:NA
Evaporation Rate & Reference:NA
Solubility in Water:MAY BE SLIGHTLY SOL.
Appearance and Odor:RED-DYED, PINK OR COLORLESS LIQUID; GASOLINE ODOR.
Percent Volatiles by Volume:100%
Corrosion Rate:NA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS.
Stability Condition to Avoid:HEAT, FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE MAY BE FORMED FROM
INCOMPLETE COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:RECYCLE AS MUCH OF THE RECOVERABLE PRODUCT AS
POSSIBLE. TREATMENT, STORAGE, TRAANSPORTATION & DISPOSAL MUST BE IN
ACCORDANCE WITH APPLICABLE FEDERAL, STATE/PROVINCIAL, AND LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SKD-NF/ZP-9B DEVELOPER(PRE 7/88) NSN CANCLD
Preparer's Name:BRUCE C. GRAHAM,CHIEF CHE
CAGE:37676
CAGE:37676
============= Composition/Information on Ingredients =============
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 90.0%
OSHA PEL:350 PPM/450 STEL
ACGIH TLV:350 PPM/450STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:PIGMENTS(MIXTURE OF CALCIUM CARBONATE,SILICA,TITANIUM
OXIDE,MAGNESIUM SOAP)-PER MFR 3/29/88
Other REC Limits:3000PPM
ACGIH TLV:5000PPM
Ingred Name:1,4-DIOXANE (DIETHYLENE DIOXIDE) (SARA III)
CAS:123-91-1
RTECS #:JG8225000
Fraction by Wt: 1.0%
OSHA PEL:S, 100 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Explanation of Carcinogenicity:DIOXANE, CAS#123-91-1, HAS SUFFICIENT
CARCINOGENIC EVIDENCE IN ANIMALS AND INADEQUATE DATA IN HUMANS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR, GIVE CPR/O*2 IF NEEDED;
EYES/SKIN: FLUSH WITH LARGE AMOUNTS OF WATER FOR 15 MIN; INGESTION:
RINSE MOUTH; GET MEDICAL ATTENTION FOR EYES,BREATHING DIFFICULTY,
OR OTHER SYMPTOMS OF OVEREXPOSURE.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NONE SPECIFIED
Fire Fighting Procedures:KEEP AEROSOL CANS COOL WITH WATER SPRY.
Unusual Fire/Explosion Hazard:VAPORS CAN DECOMPOSE TO TOXIC GASES WHEN
EXPOSED TO FLAME.CAN MAY BURST/EXPLODE IN HEAT OF FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:CAN BE ALLOWED TO EVAPORATE AWAY IF SPILLED IN
AEROSOL CAN QUANTITIES.WIPE UP WHITE RESIDUE WITH RAG.NO
SMOKING.USE PROPER PERSONAL PROTECTIVE EQUIPMENT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY AND WELL VENTILATED
AREA.KEEP CONTAINER CLOSED AND AWAY FROM HEAT SOURCES.
Other Precautions:AVOID SKIN AND EYES CONTACT.SKD-NF/ZP-9B DEVELOPER
EXERTS DRYING ACTION ON SKIN,LEADING TO IRRITATION.WIPE OFF
PROMPTLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR FOR ORGANIC
VAPORS.
Ventilation:LOCAL EXHAUST TO MAINTN BELOW TLV.
Other Protective Equipment:AS REQUIRED TO PREVENT PROLONGED CONTACT.
Supplemental Safety and Health
THIS FORMULATION EFF FROM 5/1986 TO 7/88;OLD FORMULA IS UNDER PNI-A.NSN
WAS GR II OF MIL-I-25135C,QPL-25135-13;QPL-25135-15 IDENTIFIED
PRODUCT AS TYPE II,FORM D OF MIL-I-25135D;NSN IS BEING CANCELLED
AS DUPLICATE OF 6850-01-265-2742,1 GAL QTY;PER MFR(3/29/88),ZP-9B &
SKD-NF ARE SAME,NOW SOLD UNDER SKD-NF/ZP-9B P/N.
================== Physical/Chemical Properties ==================
HCC:T4
Boiling Pt:B.P. Text:162F/72.1C
Vapor Pres:230
Vapor Density:4.5
Spec Gravity:1.3
Evaporation Rate & Reference:3.0(ETHYL ALCOHOL=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR,COLORLESS,LIQUID.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
ALKALI METALS
Stability Condition to Avoid:AVOID USING NEAR FLAME ARCS,RED HOT
SURFACES.
Hazardous Decomposition Products:PHOSGENE,HYDROCHLORIC ACID,IF VAPORS
ARE EXPOSED TO FLAMES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH LOCAL,STATE
& FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:HIGH-NICKEL AND NICKEL-BASE ALLOYS, 4N11, NI-1
CAGE:03805
CAGE:03805
============= Composition/Information on Ingredients =============
Ingred Name:CHROMIUM (CR) (SARA 313) (CERCLA)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: .01%
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3; 9495
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:NICKEL (NI) (SARA 313) (CERCLA)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 99.0%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9495
Ingred Name:TITANIUM (TI)
CAS:7440-32-6
RTECS #:XR1700000
Fraction by Wt: 1.6%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:FLUORIDES AS CRYOLITE; (SODIUM ALUMINUM FLUORIDE (AS F)
CAS:13775-53-6
OSHA PEL:2.5 PPM F
ACGIH TLV:2.5 MG/M3
Ingred Name:CALCIUM CARBONATE; (CALCIUM CARBONATE (CONTAINING SILICA)
CAS:1317-65-3
RTECS #:EV9580000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9495
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9495
Ingred Name:SODIUM SILICATE
CAS:1344-09-8
OSHA PEL:C2 (AS NAOH) (MFR)
ACGIH TLV:C2 (AS NAOH) (MFR)
Ingred Name:MANGANESE (MN) (SARA 313)
CAS:7439-96-5
RTECS #:OO9275000
OSHA PEL:C 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9495
Ingred Name:SODIUM COMPOUND; (SODIUM TITANATE)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MAGNESIUM FLUORIDE
CAS:7783-40-6
RTECS #:OM3325000
OSHA PEL:2.5 MG/M3
ACGIH TLV:2.5 MG/M3
Ingred Name:SUPDAT:CUTTING OR WELDING. PROVIDE PROTECTIVE SCREENS TO
SHIELD OTHERS.
RTECS #:9999999ZZ
Ingred Name:EYE PROT:AND/OR FACE SHIELD WHEN CUTTING, GRINDING/WELDING,
IN ADDTN, WHEN HOT CUTTING/WELDING, WEAR WELDING (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:HELMET/FACE SHIELD W/FILTER LENS. SELECT WELDING
LENS SHADE FOR AMERICAN WELDING SOCIETY (AWS) PUBLICATION F2.2.
RTECS #:9999999ZZ
Ingred Name:EXPLAN OF CARCIN:NTP 7TH ANNUAL REPORT ON CARCINOGENS,
1994: ANTICIPATED TO BE CARCINOGEN. HUMAN:LUNGS, NASAL CAVITIES.
RTECS #:9999999ZZ
Ingred Name:HAZ DECOMP PROD:TOXIC GASES; PHOSGENE. FOR MORE SPECIFIC
INFORMATION CONTACT NEHC .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ELECTRIC ARC WELDING RAYS CAN INJURE
EYES & BURN SKIN. DUST, FUMES & GASES CAN BE DANGEROUS TO YOUR
HLTH. LUNG DMG MAY RSLT FROM OVEREXP. ACUTE:SHORT TERM EXPOS TO
WELDING FUMES, GASES/DUST MAY RSLT I N DISCOMFORT SUCH AS DIZZ,
NAUS, FEVER,DRYNESS &/IRRIT OF NOSE, THROAT & EYES. SKIN
SENSITIVITY MAY (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NICKEL:IARC MONOGRAPHS ON THE EVALUATION
OF CARCINOGENIC RISK OF CHEMICALS TO MAN, VOL 49, PG 257,
1990:GROUP 2B(ING 15)
Effects of Overexposure:HLTH HAZ:MAY ALSO BE NOTED. ACUTE EXPOS CAN
RSLT IN THE SAME SYMPS EXCEPT TO GREATER DEGREE AS WELL AS WATERY
EYES, HDCH, BRTHG DFCLTY, FREQUENT COUGHING &/CHEST PAINS. SOME
GASES MAY CAUSE PULM EDEMA , ASPHY & EXCESSIVE EXPOS CAN BE
FATAL.CHRONIC:MAY RSLT IN NEUROLOGICAL DMG, LUNG FIBROSIS,
PNEUMOCONIOSIS (SUPDAT)
Medical Cond Aggravated by Exposure:SOME WORKERS MAY EXPER DISCOMFORT
AT CONCENTRATIONS BELOW THRESHOLD LIM VALUES & OTHERS MAY BE
AFFECTED BY A PRE-EXISTING CNDTN/OCCUP ILLNESS BECAUSE OF WIDE
VARIATION IN INDIVIDUAL SUSCEPTIBILITIES.
======================= First Aid Measures =======================
First Aid:IN CASE OF ELEC SHOCK, TURN OFF POWER PRIOR TO REMOVAL FROM
EXPOS AREA & ADMIN OF FIRST AID. INHAL:REMOVE TO FRESH AIR. IF
BRTHG IS DFCLT ADMINISTER OXYGEN. IF NOT BRTHG BEGIN ARTF RESP. IF
NO DETECTA BLE PULSE BEGIN EXTERNAL HEART MESSAGE.SKIN:WASH
AFFECTED AREA W/SOAP & H*2O. EYES:FLUSH W/LRG AMTS OF FRESH H*2O
FOR AT LEAST 15 MIN. INGEST:SEEK MED ATTN. IN ALL CASES, SEEK MED
ATTN FOR FIRST AID.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:ARCS, SPARKS, AND MOLTEN METAL CAN IGNITE
FLAMMABLES AND COMBUSTIBLES OR CAUSE EXPLOSIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP ANY GRINDING DUST OR WASTE RESIDUES
AND PLACE IN SUITABLE DEPARTMENT OF TRANSPORTATION (DOT) APPROVED
CONTAINERS AND DISPOSE OF IN FULL COMPLIANCE WITH FEDERAL, STATE
AND LOCAL REGULATIONS. A VOID INHALATION AND SKIN EXPOSURE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT EXPOSE SKIN TO RADIATION WHEN
HOT CUTTING OR WELDING.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE WELD FUME RESP/AIR SUPP RESP WHEN CUTTING,
GRINDING/WELDING IN A CONFINED SPACE/WHERE LOC EXHST/GEN VENT DOES
NOT KEEP EXPOS BELOW REC LIMS. MONITOR THE AIR QTY INSIDE THE
WELDER'S HELMET, IF WORN , &/THE WORKER'S BREATHING ZONE (SUPDAT)
Ventilation:USE ENOUGH VENT WHEN CUTTING, GRINDING/WELDING TO KEEP THE
DUST, FUMES & GASES FROM THE WORKERS BRTHG ZONE (SUPDAT)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . PROVIDE PROTECTIVE SCREENS TO SHIELD OTHERS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:& OTHER LUNG DISEASES. RESP PROT:TO DETERM IF A RESP IS
REQ & THE TYPE NEEDED. USE ONLY NIOSH APPRVD RESPS. VENT:& GEN
AREA. KEEP EXPOS BELOW THE LIM SPECIFIED IN INGRED & REACTIVITY D
NOT EXPOSE SKIN TO RADIATION WHEN HOT (ING 12)
================== Physical/Chemical Properties ==================
Appearance and Odor:COVERED WELDING ELECTRODES ARE SOLID WIRE WITH A
FLUX COATING.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
GASEOUS RECATION PRODUCTS MAY INCLUDE CARBON MONOXIDE, OZONE AND
NITROGEN OXIDES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OXIDES OF METALS, CHROMATES,
FLOURIDES, & COMPLEX METALLICS, CARBON MONOXIDE, OZONE, AND
NITROGEN OXIDES. (ING 16)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN FULL COMPLIANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SELENIUM 10000 UG/ML (1% W/V)
CAGE:0EK28
CAGE:0EK28
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Ingred Name:SELENOUS ACID, SELENOUS ACID
CAS:7783-00-8
RTECS #:VS7175000
OSHA PEL:200 UG/CUM
ACGIH TLV:200 UG/CUM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:NITRIC ACID, HYDROGEN NITRATE
CAS:7697-37-2
RTECS #:QU5775000
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: LIQUID MAY CAUSE BURNS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:BURNS, COUGHING, DIFFICULTY BREATHING, NAUSEA,
VOMITING, LOSS OF CONSCIOUSNESS.
======================= First Aid Measures =======================
First Aid:INGESTION: DON'T INDUCE VOMITING. IF CONSCIOUS GIVE WATER,
MILK/MILK OF MAGNESIA. SKIN/EYES: FLUSH W/PLENTY OF WATER FOR 15
MINS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE APPROPRIATE MEDIA FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR PROPER PROTECTIVE EQUIPMENT & SELF
CONTAINED BREATHING APPARATUS W/FULL FACEPIECE OPERATED IN POSITIVE
PRESSURE MODE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SCBA & FULL PROTECTIVE CLOTHING. STOP
LEAK IF POSSIBLE W/OUT RISK. USE WATER SPRAY TO REDUCE VAPORS. TAKE
UP W/SAND/OTHER NON-COMBUSTIBLE ABSORBENT MATERIAL & PLACE INTO
CONTAINER FOR LATER DISPO SAL. FLUSH AREA W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN CORROSION-PROOF AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED.
Ventilation:LOCAL EXHAUST/VENT HOOD.
Other Protective Equipment:LAB COAT
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Spec Gravity:1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR COLORLESS SOLUTION W/NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ORGANIC MATERIALS, STRONG REDUCING AGENTS.
Hazardous Decomposition Products:TOXIC FUMES OF SELENIUM, NITROGEN
OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
ENVIRONMENTAL REGULATIONS. EPA HAZARDOUS WASTE #: CORROSIVE WASTE
D002.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ZL-54A ZYGLO WATER WASHBL PENETRNT(POST 87)
Preparer's Name:BRUCE C. GRAHAM, CH. CHEM
CAGE:37676
CAGE:37676
============= Composition/Information on Ingredients =============
Ingred Name:KEROSENE; ALIPHATIC PETROLEUM SOLVENT
CAS:8008-20-6
RTECS #:OA5500000
Fraction by Wt: 5.0%
ACGIH TLV:100 MG/CUM
Ingred Name:BENZYL ALCOHOL; BENZENEMETHONOL
CAS:100-51-6
RTECS #:DN3150000
Fraction by Wt: 10.0%
Ingred Name:PER MFR MSDS, "CONTAINS NO OTHER INGREDIENT SUSPECTED OF
BEING HAZARDOUS ACCORDING TO 29CFR1910.1200 OSHA HAZCOMM RULE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CAUSES MILD IRRITATION TO EYES
AND SKIN.
Effects of Overexposure:INHALATION: VAPORS MAY CAUSE DIZZINESS, NAUSEA.
SPRAY MIST MAY IRRITATE BREATHING PASSAGES; EYES: LIQUID CONTACT
MAY CAUSE MILD IRRITATION; SKIN: MAY CAUSE IRRITATION. DISSOLVES
SKIN OILS. INGESTION: NOT LISTED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NOT STATED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT,
GIVE OXYGEN; SKIN:REMOVE CONTAMINATED CLOTHES. WASH OFF WITH
FLOWING WATER. USE SOOTHING LOTION. IF IRRITATION PERSISTS, GET
MEDICAL ATTN; E YES: IMMEDIATELY RINSE/FLUSH WITH COPIOUS AMOUNT OF
RUNNING WATER, AND GET MEDICAL ATTENTION. INGESTION: GET MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:200F/93C
Extinguishing Media:CARBON DIOXIDE, FOAM.
Fire Fighting Procedures:KEEP CONTAINERS COOL WITH WATER SPRAY. DO NOT
SPRAY ON BURNING PRODUCT.
Unusual Fire/Explosion Hazard:WHEN INVOLVE IN COMBUSTION, MAY EMIT
TOXIC GASES AT OR ABOVE DECOMPOSITION TEMPERATURE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES.SMALL SPILL:WIPE UP OR
MOP UP BUT DO NOT BREATHE VAPORS.PLACE RAGS IN CLOSED DRUMS; LARGE
SPILL:WEAR PERSONAL SAFETY EQUIPMENTS.DIKE AREA FAR AHEAD.ABSORB
LIQUID WITH COMMERCIA L ABSORBENT.TRANSFER WASTE MATL IN SALVAGE
TANKS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HEAT SOURCES IN WELL
VENTILATED AREA. AVOID AGAINST PHYSICAL DAMAGE TO CONTAINERS. KEEP
CONTAINERS TIGHTLY CLOSED.
Other Precautions:DO NOT BREATHE VAPORS. DO NOT SMOKE WHILE USING. DO
NOT HEAT ABOVE 130F(54C). AVOID FREQUENT OR PROLONGED SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A RESPIRATOR WITH CHEMICAL CARTRIDGE. IN
CONFINED AREAS, WEAR A FULL MASK WITH SEPARATE AIR SUPPLY.
Ventilation:GENERAL VENTILATION TO KEEP BELOW 350PPM LIMIT.
Other Protective Equipment:EITHER USE IN A SPRAY BOOTH OR NEXT TO AN
EXHAUST VENT.
Work Hygienic Practices:AVOID SKIN CONTACT. WASH THOROUGHLY AFTER
HANDLING OR USE. LAUNDER CONTAMINATED CLOTTHES.
Supplemental Safety and Health
THIS REPRESENTS NEW FORMULATION OF ZL-54A;OLD FORMULATION DATA UNDER
PNI "A",THIS NSN; PER QPL-25135-15, ZL-22D,ZL-27A,ZL-37,ZL-55, AND
ZL-66A PENETRANTS ALSO QUALIFY FOR TYPE I,METH A,LVL 3 OF MIL-I-
25135,REV E IN ADDITION TO ZL-54A PENETRANT. MFR MAY SUPPLY ONE OF
THESE PENETRANTS FOR THE NSNS OF TY I,METH A,LEVEL 3.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:410F/210C
Vapor Pres:0.3 @100F
Vapor Density:>1.0
Spec Gravity:0.99
Solubility in Water:NEGLIGIBLE
Percent Volatiles by Volume:5.0%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MFR STATED "NONE".
Stability Condition to Avoid:HEAT, HIGH TEMPERATURES.
Hazardous Decomposition Products:EMITS OXIDES OF CARBON AND NITROGEN ON
COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR DISPOSE OF AS EPA HAZARDOUS WASTE
D001 (IGNITABLE WASTE),I/A/W ALL APPLICABLE FEDERAL, STATE, LOCAL
REGULATIONS; IF LOCAL AUTHORITIES PROHIBIT DUMPING RINSINGS DOWN
THE SEWER,PURIFY RINS INGS WITH MAGNAFLUX WASTE WATER TREATMENT
SYSTM.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:RECYCLED WATER BASE PAINT
CAGE:NO561
CAGE:NO561
============= Composition/Information on Ingredients =============
Ingred Name:VEHICLE (NON-HAZARDOUS)
Fraction by Wt: 65.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:MIXED ACRYLIC VINYL RESIN (NON-HAZARDOUS)
Fraction by Wt: 30.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:JUST WATER (NON-HAZARDOUS)
Fraction by Wt: 68.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:PLASTICIZER
Fraction by Wt: 1.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:PIGMENT (NON-HAZARDOUS)
Fraction by Wt: 35.0%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: HARMFUL. NOSE/THROAT
IRRITATION. EYE: IRRITATION. SKIN: IRRITATION.
Medical Cond Aggravated by Exposure:IF YOU HAVE CONDITIONS THAT COULD
BE AGGRAVATED BY ORGANIC VAPORS, SEE A PHYSICIAN PRIOR TO USE.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/WATER FOR 15 MINUTES, GET MED AID. SKIN: WASH
W/SOAP & WATER. INHAL: GET FRESH AIR. OXYGEN OR ARTIFICIAL
RESPIRATION IF NEEDED. GET MED AID. INGEST: DONT INDUCE VOMIT, GET
MED AID.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>200F,>93C
Extinguishing Media:DRY CHEMICAL, FOAM, CARBON DIOXIDE & WATER FOG.
Unusual Fire/Explosion Hazard:THIS IS A WATER BASE PRODUCT. IT CONTAINS
SMALL AMOUNTS OF VOLATILE ORGANIC COMPOUNDS. COOL SURROUNDING
CONTAINERS W/WATER IN CASEOF FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:WATER MAY BE USED TO CLEAN UP SPILLS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM IGNITS & STRONG
OXIDIZING AGENTS. KEEP CONTAINERS CLOSED. STORE IN A COOL, DRY WELL
VENTED AREA. KEEP FROM FREEZING.
Other Precautions:DONT WELD, HEAT, CUT, DRILL ON FULL OR EMPTY
CONTAINERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE ONLY W/GOOD VENTILATION.
Ventilation:REQUIRED
Other Protective Equipment:LONG SHIRT & PANTS.
Work Hygienic Practices:WASH W/SOAP & WATER BEFORE EATING, DRINKING,
APPLYING COSMETICS OR USING TOILET FACILITIES.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:441F,227C
Vapor Density:>AIR
Evaporation Rate & Reference:<ETHER
Percent Volatiles by Volume:65.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ALPINE CLEANER
CAGE:NO570
CAGE:NO570
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTOXYETHANOL
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 4.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:50 PPM
ACGIH TLV:25 PPM
Ingred Name:PRODUCT CONTAINS 5 INERT INGREDIENTS, NOT SPECIFIED.
Fraction by Wt: NA
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CAN CAUSE EYE/SKIN IRRITATION. AS WITH
ANY FOREIGN BODY CAN CAUSE NAUSEA/DIARRHEA IF INGESTED.
Effects of Overexposure:MAY CAUSE DRY SKIN & DIARRHEA.
Medical Cond Aggravated by Exposure:EYE IRRITANT.
===================== Fire Fighting Measures =====================
Flash Point:212F,100C
Extinguishing Media:NONFLAMMABLE
Unusual Fire/Explosion Hazard:NONE, AS THIS IS A WATER-BASED PRODUCT.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP LEAK. DIKE SPILL. DRY FLOOR W/ABSORBENT.
SHOVEL INTO METAL OR PLASTIC LINED CONTAINERS. EVACUATE AS FLOOR
WILL BE SLIPPERY. CLEAN FLOOR W/CLEANER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING. KEEP CONTAINER
CLOSED TO AVOID CONTAMINATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NA
Ventilation:LOCAL EXHAUST, MECHANICAL GENERAL ACCEPTIBLE.
Other Protective Equipment:NOT REQUIRED
Work Hygienic Practices:TRAIN EMPLOYEES IN PROPER HANDLING & SPILL
AVOIDANCE.
Supplemental Safety and Health
PH OF 11.9 FOR WATER-BASED SOLUTION.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:NA
Spec Gravity:1.034
Evaporation Rate & Reference:AS WATER
Solubility in Water:COMPLETE
Appearance and Odor:GREENISH-BLUE VISCOUS LIQUID, MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE W/LOCAL, STATE, FEDERAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:NICKEL SILVER
Preparer's Name:JAMES BINGHAM
CAGE:JO820
CAGE:JO820
CAGE:27911
CAGE:6L121
============= Composition/Information on Ingredients =============
Ingred Name:COPPER (SARA III)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: >46%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2MG/M3 FUME; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: >9%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9293
Ingred Name:ZINC (SARA III)
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: <39%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG ZNO/M3
ACGIH TLV:10 MG ZNO/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION OF WELDING FUMES MAY
CAUSE NERVOUS SYSTEM AND MUSCLE IRREGULARITIES, IRRITATION OF EYES,
NOSE, THROAT, AND RESPIRATORY SYSTEM, METAL FUME FEVER. CHRONIC:
INHALATION OF FUMES MAY CAUS E CANCER, SIDEROSIS, FLUOROSIS AND
AFFECT LUNG FUNCTION.
Explanation of Carcinogenicity:CONTAINS NICKEL WHICH IS LISTED BY BOTH
IARC AND NTP.
Effects of Overexposure:INHALATION: NAUSEA, DIZZINESS,DRYNESS OF NOSE
AND THROAT, COUGHING, WHEEZING AND SHORTNESS OF BREATH. EYES:
REDNESS, TEARING, BLURRED VISION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESUSCITATE IF NEEDED. EYES:
FLUSH WITH PLENTY OF WATER FOR 15 MINUTES. SEE DOCTOR. SKIN: WASH
WITH SOAP AND WATER. INGESTION: DO NOT INDUCE VOMITING. SEE DOCTOR.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:NON-FLAMMABLE; BUT SPARKS AND WELDING ARC
MAY IGNITE COMBUSTIBLES DURING USE.
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP RODS. SWEEP UP OR MOP. PLACE RESIDUE
IN A CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:REMOVE ANY COMBUSTIBLES FROM WORK
AREA: SPARKS OR WELDING ARC COULD IGNITE NEARBY COMBUSTIBLES.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR WELDING
FUMES OR SUPPLIED AIR RESPIRATOR IN CONFINED SPACES OR WHERE FUME
CONCENTRATION EXCEEDS REGULATORY LIMITS.
Ventilation:USE MECHANICAL OR LOCAL EXHAUST OR BOTH TO MAINTAIN LEVELS
OF FUMES BELOW REGULATORY LIMITS.
Other Protective Equipment:CLOTHING TO PROTECT ENTIRE BODY FROM SPARKS.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:INSOLUBLE
Appearance and Odor:SOLID ROD
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:METAL FUMES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:AMERCOAT, #65
CAGE:55849
CAGE:55849
============= Composition/Information on Ingredients =============
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 90%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE (SARA III)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/125STEL;9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:VAPOR OR SPRAY MIST CAN BE HARMFUL.
IRRITATING TO EYES, SKIN, NOSE & THROAT. REPEATED & PROLONGED
OCCUPATIONAL OVEREXPOSURE TO SOLVENTS IS ASSOCIATED WITH PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE. CANBE HARMFUL IF INHALED. CAN BE
HARMFUL OR FATAL IF SWALLOWED. OVEREXPOSURE CAN DAMAGE CENTRAL
NERVOUS SYSTEM.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EXCESSIVE INHALATION CAN CAUSE HEADACHE, NAUSEA
OR DIZZINESS. OVEREXPOSURE OR INGESTION CAN CAUSE LUNG, KIDNEY
AND/OR LIVER DAMAGE. CHEMICAL PNEUMONIA. ASPIRATION HAZARD.
Medical Cond Aggravated by Exposure:RESPIRATORY. KIDNEY AND LIVER
DISORDERS. SKIN. EYES.
======================= First Aid Measures =======================
First Aid:OVEREXPOSURE TO VAPOR OR SPRAY MISTS-PROVIDE FRESH AIR; IF
BREATHING LABORED, GIVE OXYGEN OR ARTIFICIAL RESPIRATION. FOR SKIN
CONTACT, WASH THOROUGHLY WITH SOAP & WATER. FOR EYES, FLUSH
IMMEDIATELY WI TH PLENTY OF WATER FOR AT LEAST 15 MIN & GET MEDICAL
ATTENTION. IF SWALLOWED, DRINK 1 OR 2 GLASSES OF WATER TO DILUTE.
DO NOT INDUCE VOMITING. CONSULT PHYSICIAN OR POISON CONTROL CENTER
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:78.0F,25.6C
Lower Limits:1
Upper Limits:7.00
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT, SELF-CONTAINED
BREATHING APPARATUS. ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT,
SPARKS & OPEN FLAMES.
Unusual Fire/Explosion Hazard:PREVENT STATIC DISCHARGE. AN INGREDIENT
MAY PRODUCE A FLOATING FIRE HAZARD. VAPORS MAY SPREAD LONG
DISTANCES, CAUSE FLASH FIRE OR OGNITE EXPLOSIVELY.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID BREATHING OF VAPORS. USE ABOSRBENT
CLEANUP MATERIALS. PLACE IN SEPERATE CONTAINER. KEEP OUT OF SEWERS
AND WATERWAYS. IF ENTRY IS TREATENED OR OCCURS, NOTIFY LOCAL
AUTHORITIES. ELIMINATE ALL SOUR CES OF IGNITION.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED, UPRIGHT WHEN
NOT IN USE. STORE IN COOL, DRY, WELL-VENTILATED AREA. AVOID STORAGE
TEMPERATURES ABOVE 100 DEGREES FAHRENHEIT.
Other Precautions:DO NOT TAKE INTERNALLY. AVOID PROLONGED BREATHING OF
VAPORS OR SPRAY MISTS OR CONTACT WITH SKIN AND EYES. DO NOT WELD OR
FLAME CUT AN EMPTY CONTAINER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA CERTIFIED RESPIRATOR. FOR SPECIFIC
CONDITIONS. REFER TO CURRENT NIOSH POCKET GUIDE TO CHEMICAL
HAZARDS. USE AIR-LINE RESPIRATORS IN CONFINED OR RESTRICTED
VENTILATION AREAS. REFER TO 29 CFR , OSHA PARTS 1910 AND 1915, FOR
COATINGS
Ventilation:SUFFICIENT VENTILATION IN VOLUME PATTERN SHOULD BE PROVIDED
TO KEEP AIR CONTAMINANT CENCENTRATIONS BELOW TLV LIMIT.
Other Protective Equipment:FULL PROTECTIVE CLOTHING. SPARK-PROOF
EQUIPMENT.
Work Hygienic Practices:WASH THOROUGHLY BEFORE EATING, SMOKING OR USING
WASHROOM. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
GROUND CONTAINERS WHEN POURING.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:276-277F
Vapor Density:>AIR
Evaporation Rate & Reference:LOW=0.60 HIGH=0.87
Appearance and Odor:LIQUID, SOLVENT ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS, ALKALIES.
Stability Condition to Avoid:HEAT, OPEN FLAMES, ARC OR SPARK.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN SEPERATE, CLOSED METAL CONTAINER IN
ACCORDANCE WITH ALL APPLICABLE REGULATIONS. EPA WASTE NO: D001,
U239.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:5962/BS101
CAGE:JO855
CAGE:97130
CAGE:JO855
============= Composition/Information on Ingredients =============
Ingred Name:NICKEL 63
===================== Hazards Identification =====================
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
======================= First Aid Measures =======================
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
===================== Fire Fighting Measures =====================
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
================== Accidental Release Measures ==================
======================Handling and Storage ======================
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
SOURCE OF DATA-MIL HANDBOOK 600-1 SEP 76. SAFETY & HEALTH DATA
DEVELOPED BY DGSC-STF.
================== Physical/Chemical Properties ==================
HCC:A3
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-IN ACCORDANCE WITH
DOD REGULATIONS AND FEDERAL,STATE & LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CESIUM CHLORIDE, 813700
CAGE:IO030
CAGE:30060
CAGE:IO030
============= Composition/Information on Ingredients =============
Ingred Name:CESIUM CHLORIDE
CAS:7647-17-8
RTECS #:FK9625000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC:MODERATE ORAL TOXICITY.
CAN CAUSE EYE IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING. RINSE LIBERALLY WITH WATER
FOR A CONSIDERABLE PERIOD. INGEST:IF WITHIN 15 MINUTES AFTER
OCCURENCE, MAKE PATIENT DRINK 1 OR 2 GLASSES OF WATER. EYES:RINSE
LIBERALLY W ITH WATER FOR AT LEAST 15 MINUTES. INHAL:TAKE THE
PATIENT INTO THE FRESH AIR AND ALLOW TO REST.
===================== Fire Fighting Measures =====================
Flash Point:NOT AVAILABLE
Extinguishing Media:USE EXTINGUISHING MEDIA SUITABLE FOR SURROUNDING
FIRE .
Fire Fighting Procedures:NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP INTO SUITABLE CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:2377F,1303C
Melt/Freeze Pt:M.P/F.P Text:1195F,646C
Spec Gravity:3.99
Solubility in Water:SOLUBLE
Appearance and Odor:POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BF*3
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF C1-
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR LANDFILL AS COMPLIES WITH FEDERAL,
STATE AND LOCAL LAWS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:DIRT FIGHTER EXTERIOR LATEX GLOSS FINISH (S
CAGE:59019
CAGE:59019
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL. VP:0.1
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: <5%
OSHA PEL:50 PPM C
ACGIH TLV:50 PPM, VAPOR, C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TITANIUM OXIDE;(TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 0-20%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:NICKEL ANTIMONY TITANATE
CAS:8007-18-9
Fraction by Wt: 5%
OSHA PEL:0.5 MG(SB)/M3
ACGIH TLV:0.5 MG(SB)/M3
Ingred Name:EFTS OF OVEREXP:LUNG CANCER, HOWEVER, SUCH EXPOS LEVELS ARE
NOT ATTAINABLE IN WORKPLACE. ANIMAL STUDIES HAVE (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:CLEARLY DEMONSTRATED DOSE-RELATED ADVERSE EFTS ON
CNS/HEMATOPOIETIC TISS/BLOOD/KIDNEY & LIVER ASSOC W/ (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:ADMIN OF ETHYLENE GYLCOL MONBUTYL ETHER (EGBE) AND
ETHYLENE GLYCOL MONOBUTYL ETHER ACETATE (EGBEA). (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:(EXTRACTED FROM DHHS (NIOSH) PUBLICATION NO. 90-118)
.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:KEEP CNTNR CLSD WHEN NOT IN USE. TRANSFER ONLY
TO APPRVD CNTNRS W/COMPLETE & APPROPRIATE LABELING. (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:DO NOT TAKE INTERNALLY. KEEP OUT OF THE REACH OF
CHILDREN.
RTECS #:9999999ZZ
Ingred Name:VENT:REFER TO OSHA STANDARDS 1910.94, 1910.107, 1910.108.
RTECS #:9999999ZZ
Ingred Name:ETHANOL, 2-BUTOXY-;(2-BUTOXYETHANOL) VP:0.6
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 0-5%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRIT OF EYE/SKIN & UPPER
RESPIRATORY SYSTEM. IN CONFINED AREA VAPOR IN HIGH CONCENTRATIONS
MAY CAUSE HEADACHE, NAUSEA OR DIZZINESS. REDNESS & ITCHING OR
BURNING SENSATION MAY INDICATE EYE OR EX CESS SKIN EXPOSURE. (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:CHRONIC:ETHYLENE GYLCOL IS CONSIDERED
AN ANIMAL TERATOGEN. IT HAS BEEN SHOWN TO CAUSE BIRTH DEFECTS IN
RATS & MICE AT HIGH DOSES WHEN GIVEN IN DRINKING WATER OR BY
GAVAGE. THERE IS NO EVIDENC E TO INDICATE CAUSES BIRTH DEFECTS IN
HUMANS. PROLONGED OVEREXPOSURE (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL:IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE BREATHING.
KEEP WARM AND QUIET. SKIN:WASH AFFECTED AREA THOROUGHLY WITH SOAP
AND WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE RE-USE.
EYE:FLU SH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. GET
MEDICAL ATTENTION. INGEST:CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>199F,>93C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL FOAM
Fire Fighting Procedures:FULL PROT EQUIP INCLUDING NIOSH/MSHA APPROVED
SCBA SHOULD BE USED. WATER SPRAY MAY IBE INEFFECTIVE. IF WATER IS
USED, FOG NOZZLES ARE PREFERABLE. WATER(SUP DAT)
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO
BUILD-UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE ONLY WITH ADEQUATE VENT. AVOID
BREATHING VAPOR AND SPRAY MIST. AVOID CONTACT WITH SKIN AND EYES.
WASH HANDS AFTER USING.
Other Precautions:THIS COATING MAY CONTAIN MATL CLASSIFIED AS NUISANCE
PARTICULATES, SUCH AS TITANIUM DIOXIDE/CALCIUM CARBONATE WHICH MAY
BE PRESENT AT HAZ LEVELS ONLY DURING SANDING/ABRADING OF DRIED FILM
(ING 9)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENT, WEAR NIOSH/MSHA PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESPIRATOR FOR PROTECTION AGAINST NON-VOLATILE
MATERIAL.
Ventilation:LOCAL EXHAUST PREFERABLE. GEN EXHAUST ACCEPTABLE IF EXPOS
TO MATLS IS MAINTAINED BELOW APPLICABLE EXPOS LIMITS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR TRADE NAME/PART NO:19-58 RANCHO. PH:8.5-9.4.FIRE FIGHT PROC:MAY BE
USED TO COOL CLSD CNTNRS TO PREV PRESS BUILD-UP & POSS
AUTOIGNIT/EXPLOS WHEN EXPOS TO EXTREME HEAT. EFTS OF OVEREXP:MAY
CAUSE ADV ERSE EFTS TO LIVER/URINARY & BLOOD FORMING SYS. RATS
EXPOS TO TITANIUM DIOXIDE DUST AT 250 MG/M3 DEVELOPED (ING 5)
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:SEE INGRED
Vapor Density:1
Spec Gravity:1-1.3
pH:SUPDAT
Evaporation Rate & Reference:SLOWER THAN ETHER.
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:63-72
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE:CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF METALS IN INGREDIENTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THIS PROD IS NOT HAZ AS DEFINED UNDER
RESOURCE CONSERVATION & RECOVERY ACT (RCRA) 40 CFR 261. INCINERATE
IN APPROVED FACILITY. DO NOT INCINERATE CLOSED CONTAINER. DISPOSE
OF IN ACCORDANCE W /FEDERAL, STATE, & LOCAL REGS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:AIRFLEX PRODUCT MODEL VE
Preparer's Name:PAUL SHOWALTER
CAGE:99185
CAGE:99185
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE, TETRAFLUORO-, POLYMER; (TEFLON). SPEC GRAV:2.2.
PEL/TLV AS NUISANCE PARTICULATES
CAS:116-14-3
RTECS #:KX4025000
OSHA PEL:15MG/M3TDUST;5 RDUST
ACGIH TLV:10MG/M3TDUST
Ingred Name:GRAPHITE. MP:6040F. SPEC GRAV:2.2
CAS:7782-42-5
RTECS #:MD9659600
OSHA PEL:15 MPPCF RDUST
ACGIH TLV:2 MG/M3 RDUST; 9293
Ingred Name:BARIUM SULFATE
CAS:7727-43-7
RTECS #:CR0600000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:SUPP DATA:EXPOS ARE NOT LASTING & ARE NOT CUMULATIVE.
GRAPHITE:COMMON SYMPS ARE COUGHING, DYSPNEA, BLACK SPUTUM, (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:IMPAIRED PULM FUNCTION & PROMOTING FIBROSIS. BARIUM
SULFATE:POSS SYMPS ARE MUSCLE SPASMS, SLOW PULSE RATE,(ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:STOMACH PAINS, IRREGULAR HEART BEAT, RINGING OF EARS,
DIZZ & CONVULSIONS; DEATH MAY OCCUR IN SEVERE CASES.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:WHILE THIS MATL PRESENTS NO
SIGNIFICANT HLTH HAZ DURING NORM STOR, HNDLG & USE, EXPOS TO
DUST/FUMES FROM THIS MATL CAN CAUSE IRRIT OF EYES &/OR RESP SYS &
CAN BE A SERIOUS HLTH HAZ & REQS THAT SPEC PR ECS BE TAKEN.
TEFLON:NO TOX EFTS ARE KNOWN TO BE ASSOC W/INHAL & INGEST UNDER
NORM CNDTNS, BUT HEATING (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:500F CAN CAUSE DECOMP WHICH CAN PRDCE
INJURIOUS FUME. HEATING >750F CAN CAUSE FURTHER DECOMP WHICH CAN
PRDCE TOX FUMES. HOWEVER, NO LETHAL EFT HAS BEEN DOCUMENTED
REGARDING HUMAN EXPOS. RATHE R, INHAL OF DECOMP FUMES CAN CAUSE
TEMPINFLUENZA-LIKE SYMPS (DESCRIBED AS "POLYMER FUME FEVER"), INCL
(SUPP DATA)
Medical Cond Aggravated by Exposure:RESPIRATORY PROBLEMS IN GENERAL, &
DERMATITIS.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE VICTIM TO FRESH AIR. OBTAIN MEDICAL ATTENTION.
EYE:FLUSH W/WATER FOR AT LEAST 15 MINS TO REMOVE PARTICULATE,
OBTAIN MEDICAL ATTENTION. SKIN:WASH THOROUGHLY W/SOAP & WATER. IF
IRRITATION D EVELOPS, OBTAIN MEDICAL ATTENTION. INGEST:OBTAIN
MEDICAL ATTENTION IF QUANTITIES ARE INGESTED.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:DUST MAY PRESENT AN EXPOS HAZ IF FINELY
DIVIDED, DISPERSED IN AIR & EXPOSED TO A SOURCE OF IGNITION. ALSO,
HEATING OF BARIUM SULFATE W/ALUM CAN PRDCE AN EXPLOS.
================== Accidental Release Measures ==================
Spill Release Procedures:ANY RELEASE OR SPILL WHICH MAY INVOLVE DUST
SHOULD BE VACUUMED OR WET-SWEPT TO AVOID GENERATING AIRBORNE DUST.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:IN GENERAL, NO SPECIAL PRECAUTIONS IN
HANDLING & STORAGE ARE REQUIRED.
Other Precautions:HOWEVER, GOOD HOUSEKEEPING PRACTICES SHOULD BE
OBSERVED TO PREVENT ANY ACCUMULATIONS OF DUST & CONTACT
W/INCOMPATIBLE MATERIALS SHOULD BE AVOIDED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR IF EXPOSURE
TO DUST OR FUME IS POSSIBLE.
Ventilation:LOCAL &/OR GENERAL EXHAUST SHOULD BE USED TO KEEP AIRBORNE
CONTAMINANTS BELOW TLV'S.
Other Protective Equipment:BARRIER CREAMS MAY BE NECESSARY TO PREVENT
DERMATITIS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MATLS TO AVOID: SULFATE:ALUM & PHOSPHORUS. HAZ DECOMP PROD: FUMES WHEN
HEATED TO DECOMP. EFTS OF OVEREXP: FEVER, CHILLS, COUGH & MALAISE.
SYMPTOMS DO NOT NORM OCCUR UNTIL AT LEAST 2 HRS AFTER EXPOSURE &
USUALLY CEASE WITHIN 48 HRS AFTER EXPOSURE, EVEN W/OUT MED
TREATMENT. OBSERVATIONS HAVE INDICATED EFTS OF (ING 4)
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:SEE INGRED
Spec Gravity:SEE INGRED
Solubility in Water:INSOLUBLE
Appearance and Odor:SOLID OR ENCAPSULATED FORM.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
TEFLON:NONE. GRAPHITE:STRONG OXIDIZERS SUCH AS FLUORINE, CHLORINE
TRIFLUORIDE & POTASSIUM PEROXIDE. BARIUM (SUPP DATA)
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TEFLON:IRRIT FUMES WHEN HEATED >260C &
TOX FUMES WHEN HEATED >400C. GRAPHITE:NO DATA. BARIUM SULFATE:TOX
(SUPP DATA)
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW LOCAL, STATE & FEDERAL REGULATIONS FOR
DISPOSAL OF SOLID, ENCAPSULATED OR POWDERED (WEAR DEBRIS-TYPICALLY
DUST) WASTE CONTAINING SPECIFIED HAZARDOUS INGREDIENTS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:139 7371,EKTAPRNT R-100 1ST DEVLPR STARTER
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:AQUEOUS SOLUTION,HAZARD UNKNOWN,UNIDENTIFIED INGREDIENTS
Fraction by Wt: 100%
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:SEE SIGNS AND SYMPTOMS OF
OVEREXPOSURE.
Explanation of Carcinogenicity:NONE NOTED BY MANUFACTURER.
Effects of Overexposure:NONE NOTED BY MANUFACTURER:LOW TOXICITY AND LOW
HAZARD TO HEALTH.
Medical Cond Aggravated by Exposure:NONE NOTED
======================= First Aid Measures =======================
First Aid:INHALE:REMOVE TO FRESH AIR,GIVE CPR/O*2 IF
NEED;EYES/SKIN:FLUSH W LG AMTS H*2O FOR 15 MIN;INGEST:RINSE
MOUTH,CALL PHYSICIAN(USE STANDARD LOW TOXICITY CHEMICAL FIRST AID)
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NON FLAMMABLE:USE MEDIA SUITABLE FOR SURROUNDING
FIRE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER.
CONSULT AGENCIES FOR COMPLIANCE WITH ENVIRONMENTAL REGULATIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA.KEEP CONTAINERS TIGHTLY CLOSED. PROTECT FROM PHYSICAL DAMAGE.
Other Precautions:MAINTAIN STANDARD HYGIENE FOR CHEMICAL HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED.
Ventilation:NO SPECIAL REQUIREMENTS.
Other Protective Equipment:NO SPECIAL REQUIREMENTS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>212F/100C
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.27
pH:9.3
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR,ODORLESS AQUEOUS MIXTURE
Percent Volatiles by Volume:69
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH TO SEWER WITH PLENTY OF WATER.HANDLE AND
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE AND LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:03-R-26 CATALYST,RED 11136
Kit Part:Y
CAGE:EO418
CAGE:EO418
CAGE:33461
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 40.0%
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-ETHOXYETHYL ACETATE (CELLOSOLVE ACETATE) (EGEEA)
CAS:111-15-9
RTECS #:KK8225000
Fraction by Wt: 10.0%
OSHA PEL:S,100 PPM
ACGIH TLV:S, 5 PPM; 9192
Ingred Name:METHYL ISOBUTYL KETONE (SARA III)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 10.0%
OSHA PEL:100 PPM/75 STEL
ACGIH TLV:50 PPM/75 STEL; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: <5.0%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <5.0%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:SKIN/EYES:IRRITATION;INH:IRRIT OF RESP
TRACT/ACUTE NERVOUS SYSTEM DEPRESSION;HEADACHE,DIZZINESS,ETC.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH IMMED W.LG VOLUM OF WATER FOR AT LEAST 15 MIN.GET
MED ATTN;SKIN:WASH AFFECTED AREA W/WATER.REMOVE CONTAMINATED
CLOTHING.GET MED ATTN IF IRRIT OCCURS;INH:REMOVE FROM
EXPOSURE.RESTORE BREATHI NG BY CPR,KEEP WARM & QUIET.GET MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:20F(-6.6C)-TCC
Lower Limits:UNK
Upper Limits:UNK
Extinguishing Media:CARBON DIOXIDE,FOAM OR DRY CHEM.(CLASS B FIRE
EXTINGUISHER)
Fire Fighting Procedures:SELF-CNTND BRTHG APP;WATER SPRAY TO COOL FIRE
EXPOSED CONTNR
Unusual Fire/Explosion Hazard:CLOSED CONTNRS MAY EXPLODE IN HEAT OF
FIRE;SPILL/RUNOFF MAY CAUSE POLLUTION,FIRE&/OR EXPLSION HAZRD
================== Accidental Release Measures ==================
Spill Release Procedures:ELIM IGN SOURCES.VENTILATE AREA.USE PROTECTV
EQUIP.STOP LEAK W/O RISK.SM SPILL:CONTAIN/REMOVE W/INERT ABSORBENT
& NON-SPARKING TOOLS.PLACE IN COVERD CONTNRS;LG SPILL:DIKE AREA &
PUMP LIQ TO SALVAGE TA NK.ABSORB REMAINING LIQ & SHOVEL UP
INTOCONTAINR.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY WELL VENTILATED,LOW
FIRE RISK AREA.KEEP CLOSURE TIGHT & CONTNR UPRIGHT.STORE AWAY FM
IGNITION/HEAT SOURCES.PROTECT FM PHYSICAL DAMAG
Other Precautions:PREVENT PROLONGD/REPEATD BREATHING OF VAP OR SPRAY
MSIT.CAN CAUSE ALLERGIC REACTION.FOLLOW SPECIAL PRECAUTIONS TO
APPLY ON HOT SURFACES.IFF WATER IS USED FOR FIRE,FOG NOZZLES ARE
PRFERABLE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR FOR
PAINT,LAQUER,ENAMEL MISTS/ORGANIC VAP.
Ventilation:ADEQUATE USING EXHAUS FAN OR IAW 29CFR PART 1910.94
Other Protective Equipment:CLEAN,LONG SLEEVE/LONG LEG PROTECTIVE
CLOTHING.
Supplemental Safety and Health
MSDS FM MFR DATED:10/28/80;TWO PART RESIN MODIFIED POLYURETHANE
COATING;SEE P/N IND "C" FOR OTHER INGREDIENTS OF THIS ITEM;SPEC REF
MIL-C-83286B,TYPE 1, CLASS A. KEY1:F3.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:175-313F
Vapor Density:>1.0
Spec Gravity:0.9023
Evaporation Rate & Reference:<1(SLWR THAN ETHR)
Solubility in Water:NEGILGIBLE
Appearance and Odor:CLEAR THIN ORGANIC LIQ-ODOR OR MEK.
Percent Volatiles by Volume:76.3
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZINF/CORP MATL;ALCOHOLS,AMINES;ISOCYANATE REACTNG COMPD
Stability Condition to Avoid:SOURCES OF IGNITION/HEAT/SPARK,ETC,&
ELEVATED TEMPERATURES.
Hazardous Decomposition Products:CARBON MONO & DIOXIDE;OXIDES OF
NITROGEN.
Conditions to Avoid Polymerization:ELEVATED TEMPERATURES.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN CLOSED CONTAINERS PENDING
DISPOSAL.DISPOSE ABSORBED LIQ/RESIDUE IN CLOSED CONTNRS BY SANITARY
LANDFILL;INCINERATE LIQ IN APPROVED FACILITY.DO NOT INCINERATE
CLOSED CONTAINERS.HANDLE/DISPOSE IN FULL COMPLIANCE W/ALL
FED,STATE,& LOCALREGS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SAFE & SIMPLE WOOD STAIN, CONTEMPO MAHOGANY
CAGE:GO179
CAGE:GO179
============= Composition/Information on Ingredients =============
Ingred Name:DIPROPYLENE GLYCOL, MONOMETHYL ETHER; (DIPROPYLENE GLYCOL
MONOMETHYL ETHER)
CAS:34590-94-8
RTECS #:JM1575000
Fraction by Wt: 1%
OSHA PEL:S, 100 PPM
ACGIH TLV:S,100PPM/150 STEL
Ingred Name:DIETHYLENE GLYCOL
CAS:111-46-6
RTECS #:ID5950000
Fraction by Wt: 2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:1,2-PROPANEDIOL; (PROPYLENE GLYCOL)
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: 2%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:BRTHG HIGH CONCS OF VAPS/MISTS
MAY CAUSE IRRIT OF NOSE & THROAT, HDCH & NAUS. INGEST:INGEST OF
EXCESSIVE QTY MAY CAUSE IRRIT OF DIGESTIVE TRACT, SIGNS OF NERV SYS
DEPRESS (E.G., HDCH, DROW, DIZZ , LOSS OF COORD & FATG). PRLNGD &
RPTD INHAL, INGEST &/OR SKIN ABSORP MAY CAUSE DEGENERATION OF (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:KIDNEY & TO LESSER EXTENT, THE LIVER.
EYE CONTACT:SLIGHTLY IRRITATING. SKIN CONTACT:IRRITATION TO SKIN
UPON REPEATED OR PROLONGED CONTACT.
Medical Cond Aggravated by Exposure:RESPIRATORY SYMPTOMS ASSOCIATED
WITH PRE-EXISTING LUNG DISORDERS (E.G., ASTHMA-LIKE CONDITIONS) MAY
BE AGGRAVATED BY OVEREXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION:MOVE SUBJECT TO FRESH AIR. EYE:FLUSH WITH A LARGE
AMOUNT OF WATER FOR AT LEAST 15 MINUTES. SEE A PHYSICIAN IF
IRRITATION PERSISTS. SKIN:WASH AFFECTED SKIN AREAS WITH SOAP AND
WATER. INGESTI ON:IF SWALLOWED, DILUTE BY GIVING 2 GLASSES OF WATER
TO DRINK. SEE A PHYSICIAN. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM AND/OR WATER
SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MATERIAL CAN SPLATTER ABOVE 100C/212F.
POLYMER FILM CAN BURN.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP SPECTATORS AWAY. FLOOR MAY BE SLIPPERY;
USE CARE TO AVOID FALLING. DIKE & CNTN SPILL W/INERT MATL (E.G.,
SAND, EARTH). TRANSFER LIQ TO CNTNRS FOR RECOVERY/DISP & SOLID
DIKING MATL TO SEPARATE CNT NRS FOR DISP. KEEP SPILL OUT OF SEWERS
& (SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE TEMPERATURE MAX 49C/120F; MIN
1C/34F.
Other Precautions:KEEP FROM FREEZING-PRODUCT MAY COAGULATE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR SUITABLE RESPIRATOR (NIOSH/MSHA APPROVED OR
EQUIVALENT) WHERE EXPOSURE LIMITS ARE EXCEEDED.
Ventilation:LOCAL EXHAUST & MECHANICAL (GENERAL):YES.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER .
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING PROMPTLY AND WASH
AFFECTED SKIN AREAS WITH SOAP AND WATER. WASH CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
SPILL PROCESS:OPEN BODIES OF WATER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:VARIABLE
Vapor Pres:>17 @ 68F
Vapor Density:<1
Spec Gravity:1.04 (H*2O=1)
Evaporation Rate & Reference:<1 (ETHER=1)
Solubility in Water:DILUTABLE
Appearance and Odor:ODORLESS, HEAVY BODIED, VARIOUS COLORS.
Percent Volatiles by Volume:38%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:TEMPERATURES ABOVE 177C/350F.
Hazardous Decomposition Products:NOT APPLICABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:COAGULATE THE EMULSION BY THE STEPWISE ADDITION
OF FERRIC CHLORIDE AND LIME. REMOVE THE CLEAR SUPERNATANT LIQUID
AND FLUSH TO A CHEMICAL SEWER. INCINERATE THE SOLIDS AND THE CONTAM
DIKING MATL AT PERM ITTED FACILITY ACCORD TO LOC, STATE & FED REGS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SUVA 134A
Resp. Party Other MSDS Num.:DU000693
Preparer's Name:MSDS COORDINATOR
CAGE:23037
CAGE:23037
============= Composition/Information on Ingredients =============
Ingred Name:ETHANE, 1,1,1,2-TETRAFLUORO-
CAS:811-97-2
= Wt:100.
Other REC Limits:1000 PPM, 8 & 12 HR
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:UNKNOWN IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: ETHANE,
1,1,1,2-TETRAFLUORO-GROSS OVEREXPOSURE MAY CAUSE: CENTRAL NERVOUS
SYSTEM DEPRSSION WITH DIZZINESS, CONFUSION, INCOORDINATION,
DROWSINESS OR UNCONSCIOUSNESS. IRREGULAR HEART BEAT WI TH A STRANGE
SENSATION IN THE CHEST, HEART THUMPING, APPREHENSION,
LIGHTHEADEDNESS, FEELING OF FAINTING, DIZZINESS, WEAKNESS,
SOMETIMES PROGRESSING TO LOSS OF CONSCIOUNESS AND DEATH.
SUFFOCATION, IF A IR IS DISPLACED BY VAPORS. SKIN: IMMEDIATE
EFFECTS OF OVEREXPOSURE MAY INCLUDE: FROSTBITE, IF LIQUID OR
ESCAPING VAPOR CONTACTS THE SKIN. EYE: FROSTBITE-LIKE EFFECTS MAY
OCCUR IF THE LIQUID OR ESCAPIN G VAPORS CONTACT THE EYES.
Explanation of Carcinogenicity:NONE OF THE COMPONENTS PRESENT IN THIS
MATERIAL AT CONCENTRATIONS EQUAL TO OR GREATER THAN 0.1% ARE LISTED
BY IARC, NPT, OSHA OR ACGIH AS A CARCINOGEN.
Effects of Overexposure:INHALATION: ETHANE, 1,1,1,2-TETRAFLUORO-GROSS
OVEREXPOSURE MAY CAUSE: CENTRAL NERVOUS SYSTEM DEPRSSION WITH
DIZZINESS, CONFUSION, INCOORDINATION, DROWSINESS OR
UNCONSCIOUSNESS. IRREGULAR HEART BEAT WI TH A STRANGE SENSATION IN
THE CHEST, HEART THUMPING, APPREHENSION, LIGHTHEADEDNESS, FEELING
OF FAINTING, DIZZINESS, WEAKNESS, SOMETIMES PROGRESSING TO LOSS OF
CONSCIOUNESS AND DEATH. SUFFOCATION, IF A IR IS DISPLACED BY
VAPORS. SKIN: IMMEDIATE EFFECTS OF OVEREXPOSURE MAY INCLUDE:
FROSTBITE, IF LIQUID OR ESCAPING VAPOR CONTACTS THE SKIN. EYE:
FROSTBITE-LIKE EFFECTS MAY OCCUR IF THE LIQUID OR ESCAPIN G VAPORS
CONTACT THE EYES.
Medical Cond Aggravated by Exposure:INCREASED SUSCEPTIBILITY TO EFFECTS
OF MATERIAL MAY BE OBSERVED IN PERSONS WITH PRE-EXISTING DISEASE OF
CENTRAL NERVOUS SYSTEM & CARDIOVASCULAR SYSTEM.
======================= First Aid Measures =======================
First Aid:INHALATION: IF HIGH CONCENTARATIONS INHALED, IMMEDIATELY
REMOVE TO FRESH AIR. KEEP PERSON CLAM. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRATION. IF BREATHING DIFFICULT, GIVE OXYGEN. CALL
PHYSICIAN.SKI N: IN CASE OF CONTACT, IMMEDIATELY FLUSH SKIN WITH
PLENTY WATER FOR AT LEAST 15 MINUTES, WHILE REMOVING CONTAMINATED
CLOTHING & SHOES. CALL PHYSICIAN . WASH CONTAMINATED CLOTHING
BEFORE REUSE. TREAT FOR FROSTBITE IF NECESSARY BY GENTLY WARMING
AFFECTED AREA. EYE: IN CASE OF CONTACT, IMMEDIATELY FLUSH EYES WITH
PLENTY OF WATER FOR AT LEAST 15 MINUTES. CALL PHYSICIAN. INGESTION:
INGESTION IS NOT APOTIENTIAL ROUTE OF EXPOSURE.
===================== Fire Fighting Measures =====================
Flash Point:WILL NOT BURN
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING MATERIAL.
COOL TANK/CONTAINER WITH WATER SPRAY.
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS MAY BE
REQUIRED IF CYLINDERS RUPTURE OR RELEASE UNDER FIRE CONDITIONS.
Unusual Fire/Explosion Hazard:NOT FLAMMABLE UP TO 100C AT ATMOSPHERIC
PRESSURE BUT MIXTURES WITH HIGH CONCENTRATIONS OF AIR AT ELEVATED
PRESSURE CAN BECOME COMBUSTIBLE AT AMBIENT TEMP. AS TEMPERATURE OF
MATERIAL IS INCREASED LOWER PRESSURE (>ATMOSPHERIC) CAN CREATE
SAME EFFECT. DO NOT MIX WITH HIGH CONCENTRATIONS OF AIR ABOVE
ATMOSPHERIC PRESSURE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA, ESPECIALLY LOW OR ENCLOSED
PLACES WHERE HEAVY VAPORS MIGHT COLLECT. REMOVE OPEN FLAMES. USE
SELF-CONTIANED BRATHING APPARATUS (SCBA) IF LARGE SPILL OR LEAK
OCCURS.
======================Handling and Storage ======================
Handling and Storage Precautions:USE WITH SUFFICIENT VENTILATION TO
KEEP EMPLOYEE EXPOSURE BELOW RECOMMENDED LIMITS. HFC-134A SHOULD
NOT BE MIXED WITH AIR FOR LEAK TESTING OR USED FOR ANY OTHER
PURPOSE ABOVE ATMOSPHERIC PRESSURE. SE E FLAMMABLE PROPERTIES
SECTION. STORE IN A CLEAN, DRY PALCE. DO NOT HEAT ABOVE 52C (126
F).
Other Precautions:AVOID CONTACT WITH CHLORINE OR OTHER STRONG OXIDIZING
AGENTS SHOULD BE AVOIDED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:UNDER NORMAL MANUFACTURING CONDITIONS, NO
RESPIRATORY PROTECTION IS REQUIRED WHEN USING THIS PRODUCT.
SELF-CONTAINED BREATHING APPATATUS (SCBA) IS REQUIRED IF A LARGE
RELEASE OCCURS.
Ventilation:NORMAL VENTILATION FOR STANDARD MANUFACTURING PROCEDURES IS
GENERALLY ADEQUATE. LOCAL EXHAUST SHOULD BE USED WHEN LARGE AMOUNTS
ARE RELEASED.
Other Protective Equipment:NOT PROVIDED
Work Hygienic Practices:NOT PROVIDED
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:G3
Boiling Pt:=-26.5C, -15.7F
Vapor Pres:96 PSIA @ 25C
Vapor Density:3.6
Spec Gravity:1.208 @ 77F
Evaporation Rate & Reference:>1 (CCL4=1)
Solubility in Water:0.15 WT% @ 25C
Appearance and Odor:COLORLESS, LIQUIFIED GAS, SLIGHT ETHER ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE WITH ALKALI OR ALKALINE EARTH METALS-POWDERED AL. ZN, BE,
ETC.
Stability Condition to Avoid:AVOID OPEN FLAMES AND HIGH TEMPERATURES.
Hazardous Decomposition Products:DECOMPOSITION PRODUCTS ARE HAZARDOUS.
THIS MATERIAL CAN BE DECOMPSED BY HITH TEMPERATURES (OPEN FLAMES,
GLOWING METAL SURFACES, ETC.) FORMING HYDROFLUORIC ACID AND
POSSIBLY CARBONYL FLUORIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:SHORT DURATION OF VAPOR SPRAY PRODUCED VERY
SLIGHT EYE IRRITATION. ANIMAL TESTING INDICATES MATERIAL IS SLIGHT
SKIN IRRITANT BUT NOT SKIN SENSITIZER. INHALATION: 4 HR, ALC, RAT:
567000 PPM. SINGLE EXP OSURE CAUSED CARDIAC SENSITIZATION, A
POTENTIALLY FATAL DISTURBANCE OF HEART RHYTHM ASSOCIATED WITH
HEIGHTENED SENSITIVITY TO ACTION OF EPINEPHRINE. LOWEST OBSERVED
ADVERSE EFFECT LEVEL FOR CARDIAC SE NSITIZATION: 75000 PPM. SINGLE
EXPOSURE CAUSED LETHARGY, NARCOSIS, INCREASED RESPIRATORY RATES
(TEMPORARY EFFECTS). SINGLE DOSE TO NEAR LETHAL DOSE: PULMONARY
EDEMA. CONTINUED IN OTHER INFORMATION FIE LD.
===================== Ecological Information =====================
Ecological:AQUATIC TOXICITY: 48 HR EC50 - DAPHNIA MAGNA: 980 MG/L; 96
HR LC50 - RAINBOW TROUT: 450 MG/L.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTAMINATED HFC-134A CAN BE RECOVERED BY
DISTILLATION OR REMOVED TO A PERMITTED WASTE DISPOSAL FACILITY.
COMPLY WITH FEDERAL, STATE, AND LOCAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:DOT INFORMATION: 1,1,1,2-TETRAFLUOROETHANE, 2.2,
UN NO 3159, NONFLAMMABLE GAS LABEL.
===================== Regulatory Information =====================
SARA Title III Information:SARA SECTION 311/312 CLASSES: ACUTE,
CHRONIC, PRESSURE. NOT ON SARA EHS, CERCLA HAZARDOUS SUBSTANCE,
SARA TOXIC CHEMICAL LISTS.
Federal Regulatory Information:INCLUDED IN TSCA INVENTORY.
State Regulatory Information:NOT PROVIDED
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:TG 76
CAGE:74276
CAGE:74276
============= Composition/Information on Ingredients =============
Ingred Name:CESIUM 137
================== Accidental Release Measures ==================
============= Exposure Controls/Personal Protection =============
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:A3
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CARBON DIOXIDE
Preparer's Name:SFETY & HEALTH DEPT
CAGE:03670
CAGE:03670
CAGE:99539
CAGE:06556
CAGE:0D8W3
============= Composition/Information on Ingredients =============
Ingred Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: 100%
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM/30000STEL;93
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV IS 5000 PPM.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE- CONTACT WITH COLD VAPOR/SOLID
CARBON DIOXIDE CAN CAUSE EYE/SKIN FROSTBITE AND FREEZE BURNS.
ASPHYXIANT BY INHALATION. CAN INCREASE RATE OF BREATHING.
INHALATION OF >12% CAUSES RAPID UNCONSCIOUS NESS. INGESTION IS
UNLIKELY. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:EYE OR SKIN FROSTBITE AND FREEZE BURNS.
MODERATE CONCENTRATION OF CARBON DIOXIDE MAY CAUSE HEADACHE,
DROWSINESS, DIZZINESS, STINGING OF THE NOSE AND THROAT, EXCITATION,
RAPID BREATHING AND HEART RATE, EXCESS SALIVATION, SHORTNESS OF
BREATH, MUSCULAR WEAKNESS, RINGING IN THE EAR AND UNCONSCIOUSNESS
BY INHALATION.
Medical Cond Aggravated by Exposure:RESPIRATORY PROBLEMS
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. PROVIDE CPR/OXYGEN IF NEEDED.
EYES:IMMEDIATELY FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SEE AN
OPHTHALMOLOGIST, URGENTLY. SKIN:FLUSH WITH WARM WATER (NOT TO
EXCEED 105 F). PROMPT MEDICAL ATTENTION IS MANDATORY IN ALL CASES
OF OVEREXPOSURE TO CO2. RESCUE PERSONNEL SHOULD BE EQUIPPED WITH
SELF CONTAINED BREATHING APPARATUS.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:CARBON DIOXIDE CANNOT CATCH FIRE. USE WATER FOG,
CARBON DIOXIDE, FOAM, OR DRY CHEMICAL FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
NIOSH-APPROVED SELF CONTAINED BREATHING APPARATUS. COOL FIRE
EXPOSED CONTAINERS WITH WATER SPRAY. EVACUATE AREA.
Unusual Fire/Explosion Hazard:THOUGH GAS CYLINDERS ARE EQUIPPED WITH
PRESSURE AND TEMPERATURE RELIEF DEVICES, THEY SHOULD BE REMOVED
FROM HIGH TEMPERATURES OR FIRE TO AVOID RISK OF RUPTURE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE PERSONNEL. USE PROTECTIVE EQUIPMENT.
VENTILATE AREA AND AVOID CONTACT WITH SOLID OR LIQUID AND EXCESSIVE
INHALATION OF VAPOR. MOVE LEAKING CONTAINER TO WELL-VENTILATED
AREA. TEST AREA FOR SUF FICIENT OXYGEN CONTENT PRIOR TO ALLOW
RE-ENTRY.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, WELL-VENTILATED DARK
PLACE. NEVER WORK ON A PRESSURIZED SYSTEM. IF THERE IS A LEAK,
CLOSE THE CYLINDER VALVE AND BLOW DOWN THE SYSTEM
Other Precautions:KEEP AWAY FROM SOURCES OF HEAT. CAUTION! CAN CAUSE
RAPID SUFFOCATION DUE TO OXYGEN DEFICIENCY. USE WITH ADEQUATE
VENTILATION. CO2 IS HEAVIER THAN AIR AND TENDS TO ACCUMULATE NEAR
THE FLOOR IN CLOSED S PACES. READ ALL LABELS AND INSTRUCTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL USE. HOWEVER,
AIR-SUPPLIED RESPIRATORS ARE REQUIRED WHILE WORKING IN CONFINED
SPACES WITH THIS PRODUCT. THE RESPIRATORY PROTECTION USE MUST
CONFORM WITH OSHA RULES AS SPECIF IED IN 29 CFR 1910.134.
Ventilation:LOCAL EXHAUST TO CONTROL THE CONCENTRATION OF THIS PRODUCT
IN WORKER'S BREATHING ZONE. MECHANICAL/GENERAL ACCEPTABLE.
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER,
INDUSTRIAL-TYPE WORK CLOTHING, SAFETY SHOES AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
USE A SAFETY LINE AND A STANDBY WORKER WHEN RESPIRATOR-PROTECTED
PERSONNEL ENTER A HAZARDOUS CARBON DIOXIDE-ENRICHED AREA.
================== Physical/Chemical Properties ==================
HCC:G3
Boiling Pt:B.P. Text:SUBLIMES
Melt/Freeze Pt:M.P/F.P Text:NOT KNOWN
Decomp Temp:Decomp Text:NOT KNOWN
Vapor Pres:42911 @20C
Vapor Density:1.5
Spec Gravity:1.98
Evaporation Rate & Reference:GAS AT ROOM TEMPERATURE
Solubility in Water:88ML CO2/100 ML @20C
Appearance and Odor:COLORLESS GAS AT NORMAL TEMPERATURE AND PRESSURE -
NO ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
EXPLOSION CAN OCCUR IF CO2 CONTACTS SODIUM PEROXIDE MIXED WITH
ALUMINUM/MAGNESIUM. REACTIVE METALS, SODIUM POTASSIUM
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:IN THE PRESENCE OF AN ELECTRICAL
DISCHARGE, CARBON DIOXIDE IS DECOMPOSED TO FORM CARBON MONOXIDE AND
OXYGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:SLOWLY RELEASE INTO ATMOSPHERE OUTDOORS.
DISPOSAL SHOULD BE IN COMPLIANCE WITH ALL LOCAL, STATE AND FEDERAL
REGULATIONS. DEFECTIVE CYLINDERS SHOULD BE TAGGED TO INDICATE A
DEFECT. CLOSE THE VALVE AND RETURN THE DEFECTIVE CYLINDER TO THE
SUPPLIER.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ULTRA-HIDE INTERIOR CEILING SPRAY TEXTURE 5398
CAGE:01PD6
CAGE:01PD6
============= Composition/Information on Ingredients =============
Ingred Name:LIMESTONE
CAS:1317-65-3
RTECS #:EV9580000
Minumum % Wt:10.
Maxumum % Wt:20.
OSHA PEL:5 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Minumum % Wt:30.
Maxumum % Wt:40.
Ingred Name:SILICIC ACID, ALUMINUM SODIUM SALT
CAS:1344-00-9
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:0.1 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Minumum % Wt:10.
Maxumum % Wt:20.
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.1 MG/M3
Ingred Name:PERLITE, EXPANDED
CAS:93763-70-3
RTECS #:SD5254000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:ETHANOL, 2-(2-BUTOXYETHOXY)-, ACETATE
CAS:124-17-4
RTECS #:KJ9275000
Minumum % Wt:1.
Maxumum % Wt:5.
Ingred Name:ACETIC ACID ETHENYL ESTER
CAS:108-05-4
RTECS #:AK0875000
< Wt:1.
OSHA PEL:10 PPM
OSHA STEL:20 PPM
ACGIH TLV:10 PPM
ACGIH STEL:20 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VINYL ACRYLIC COPOLYMER
Minumum % Wt:10.
Maxumum % Wt:20.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:REPORTS HAVE ASSOCIATED REPEATED AND
PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN AND NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING AND INHALING THE CONTENTS MAY BE
HARMFUL OR FATAL.
Explanation of Carcinogenicity:PRODUCTS IN THIS SERIES CONTAIN
CRYSTALLINE SILICA, WHICH IS CONSIDERED A HAZARD BY INHALATION.
PRODUCTS IN THIS SERIES CONTAIN VINYL ACETATE WHICH HAS CAUSED
TREATMENT RELATED NASAL TUMORS IN RATS AN D MICE EXPOSED VIA
INHALATION FOR TWO YEARS. PRODUCTS IN THIS SERIES CONTAIN ETHYLENE
GLYCOL WHEN TINTED W/ DRAMATONE. MAY CAUSE SEVERE KIDNEY DAMAGE.
Effects of Overexposure:INHALATION: IRRITATION OF RESPIRATORY TRACT.
PROLONGED INHALATION MAY LEAD TO DROWSINESS, DIZZINESS AND/OR
LIGHTHEADEDNESS. SKIN: IRRITATION OF SKIN. CAN CAUSE DERMATITIS,
DEFATTING.EYE: IRRITAT ION OF EYES. CAN CAUSE CORNEAL INJURY.
INGESTION: MAY CAUSE LUNG INFLAMMATION AND DAMAGE DUE TO ASPIRATION
OF MATERIAL INTO LUNGS.
Medical Cond Aggravated by Exposure:INGREDIENTS CONTAINED IN THESE
PRODUCTS HAVE BEEN REPORTED TO AGGRAVATE PREEXISTING EYE, SKIN,
RESPIRATORY AND LUNG DISORDERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE AND SUPPORT
BREATHING.HAVE TRAINED PERSON GIVE OXYGEN IF NECESSARY. SKIN:
WASH OFF QUICKLY WITH PLENTY OF WATER, THEN SOAP AND WATER; REMOVE
CONTAMINATED C LOTHING. WASH CONTAMINATED CLOTHING BEFORE REUSE.
EYE: FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF WATER, ESPECIALLY
UNDER LIDS FOR AT LEAST 15 MINUTES. INGESTION: IF SWALLOWED, OBTAIN
MEDICAL TREATMENT IMMEDIATELY! IN ALL CASES, SEEK IMMEDIATE
MEDICAL ATTENTION!
===================== Fire Fighting Measures =====================
Flash Point:>93.3C, 200.F
Extinguishing Media:DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:WATER MAY BE USED TO COOL AND PROTECT EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY BURST IF EXPOSED
TO EXTREME HEAT OR FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:COMPLY WITH ALL APPLICABLE HEALTH AND
ENVIRONMENTAL REGULATIONS. VENTILATE AREA. SPILLS MAY BE COLLECTED
WITH ABSORBENT MATERIALS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 100 F. KEEP FROM
FREEZING.
Other Precautions:USE ONLY WITH ADEQUATE VENTILATION. DO NOT TAKE
INTERNALLY. KEEP OUT OF REACH OF CHILDREN. AVOID CONTACT WITH SKIN
AND EYES, AND BREATHING OF VAPORS. WASH HANDS THOROUGHLY AFTER
HANDLING, ESPECIALLY B EFORE EATING OR SMOKING. KEEP CONTAINERS
TIGHTLY CLOSED AND UPRIGHT WHEN NOT IN USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW
APPLICABLE STANDARDS. WHERE RESPIRATORY PROTECTION IS REQUIRED,
USE ONLY NIOSH/MSHA APPROVED RESPIRATORS IN ACCORDANCE WITH OSHA
STANDARD 29 CFR 1910.134.
Ventilation:PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT
BUILD-UP OF VAPORS.
Other Protective Equipment:EYE WASH, SAFETY SHOWER
Supplemental Safety and Health
WT/GAL: 12.1
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:162-455F
Percent Volatiles by Volume:48.3
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, ALUMINUM, HYDROFLUORIC ACID.
Stability Condition to Avoid:ELEVATED TEMPERATURES, CONTACT WITH
OXIDIZING AGENT.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
=================== MSDS Transport Information ===================
Transport Information:DOT PROPER SHIPPING NAME: PAINT.
===================== Regulatory Information =====================
SARA Title III Information:SARA 302: VINYL ACETATE; SARA 313:
DIETHYLENE GLYCOL MONOBUTYL ETHER ACETATE, VINYL ACETATE
Federal Regulatory Information:CERCLA: VINYL ACETATE
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:#88 ACRYLIC ENAMEL BASES & COLORS
CAGE:OUH50
CAGE:0FWV2
CAGE:OUH50
============= Composition/Information on Ingredients =============
Ingred Name:RULE 66 MINERAL SPIRITS
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 6-7%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:SOLVENT NAPHTHA
CAS:84742-94-6
Fraction by Wt: 6-7%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:VOC = 256 G/L
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: DROWSINESS, SLURRED SPEECH,
NAUSEA, HEADACHE, LIGHTHEADEDNESS, BRAIN/NS DAMAGE, DEATH. SKIN:
IRRITATION.
======================= First Aid Measures =======================
First Aid:EYE: IMMED FLUSH W/WATER. REMOVE CONTACTS. THEN FLUSH FOR 15
MINUTES, LIFT LIDS. GET MED AID. SKIN: RINSE W/COPIOUS AMOUNTS SOAP
& WATER FOR >5 MINUTES. IMMED REMOVE CONTAM CLOTHES, CALL DR.
INHAL: GE T FRESH AIR IMMED. GIVE OXYGEN OR ARTIFRESP IF REQUIRED.
INGEST: IF CONSCIOUS/NOT CONVULSING, GIVE 1-2 GLASSES WATER/MILK.
GET MED AID. NEVER GIVE ANYTHING BY MOUTH TO UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:>105F,>41C
Lower Limits:1.0
Upper Limits:7.0
Extinguishing Media:INORGANIC DRY CHEMICAL EXTINGUISHING COMPOUNDS,
CARBON DIOXIDE, FOAM.
Fire Fighting Procedures:USE FULL EMERGENCY EQUIPMENT W/SCBA. MOVE
CONTAINER FROM FIRE AREA IF POSSIBLE. COOL BY SPRAYING W/WATER OR
FOAM. EVAC IF CNTNRS VENT/DISCOLORED DUE TO FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITS. VENT AREA. WEAR PROTECTIVE
CLOTHING & SCBA. ABSORB. DIKE. CONTAINERIZE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM IGNITS. KEEP CONTAINER
CLOSED WHEN NOT IN USE. KEEP AWAY FROM CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED ORGANIC VAPOR RESPIRATOR
OR FULL FACE AIR SUPPLIED RESPIRATOR.
Ventilation:LOCAL EHAUST. TEN AIR CHANGES PER HOUR IS RECOMMENDED.
Other Protective Equipment:FULL FACE AIR SUPLIED RESPIRATOR IF NEEDED.
AS NECESSARY TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:348 TO 338F
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:4.0
Vapor Density:>AIR.
Spec Gravity:15 TO 16
pH:NA
Solubility in Water:NEGLIGIBLE.
Appearance and Odor:OPAQUE LIQUID, W/CHARACTERISTIC ODOR.
Percent Volatiles by Volume:12-14
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OIDIZERS, SULFURIC ACID, STRONG BASES.
Stability Condition to Avoid:IGNITION SCOURECES.
Hazardous Decomposition Products:CARBON OXIDES, NITROGEN OXIDES,
HYDROGEN CHLORIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OR INCINERATE SOLIDIFIED WASTE IN
ACCORDANCE W/APPROPRIATE FEDERAL/STATE/LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:L61Y25 MEDIUM YELLOW
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA, LACOLENE
CAS:64742-89-8
Fraction by Wt: 14%
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:TOLUENE (IARC CARC- GROUP 3) *96-2*
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 9%
Other REC Limits:375 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *96-2*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 2%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHANOL (METHYL ALCOHOL), COLUMBIAN SPIRITS *96-2*
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 2%
Other REC Limits:200 PPM
OSHA PEL:200 PPM
ACGIH TLV:200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL(IARC CANCER REVIEW GROUP 3) *96-2*
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 4%
Other REC Limits:400 PPM
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
Ingred Name:ISOBUTANOL, 2-METHYL-1-PROPANOL, ISOBUTYL ALCOHOL
CAS:78-83-1
RTECS #:NP9625000
Fraction by Wt: 8%
Other REC Limits:50 PPM
OSHA PEL:50 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-BUTOXYETHANOL (ETHYLENE GLYCOL MONOBUTYL ETHER), BUTYL
CELLOSOLVE, BUTYL GLYCOL, GLYCOL ETHER EB * 96-2 *
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 3%
Other REC Limits:25 PPM (SKIN)
OSHA PEL:25 PPM (SKIN)
ACGIH TLV:25 PPM (SKIN)
Ingred Name:METHYL ETHYL KETONE, 2-BUTANONE *96-2*
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 1%
Other REC Limits:590 MG/CUM
OSHA PEL:200 PPM
ACGIH TLV:200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOBUTYL ACETATE
CAS:110-19-0
RTECS #:AI4025000
Fraction by Wt: 17%
Other REC Limits:150 PPM
OSHA PEL:150 PPM
ACGIH TLV:150 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
CARCINOGEN, IARC GROUP 3)*96-2*
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 1%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:LEAD SULFOCHROMATE YELLOW, CHROME YELLOW LIGHT *96-2*
CAS:1344-37-2
Fraction by Wt: 10%
OSHA PEL:0.05 MG/CUM PB
ACGIH TLV:0.05 MG/CUM CR
Ingred Name:LEAD COMPOUND
Fraction by Wt: 15.8%
Ingred Name:CHROMIUM COMPOUNDS (TYPE NOT SPECIFIED)
Fraction by Wt: 11.2%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF EYES, SKIN & RESPIRATORY
SYSTEM, MAY CAUSE NERVOUS SYSTEM DEPRESSION & DEATH. OVEREXPOSURE
TO LEAD MAY RESULT IN DAMAGE TO THE BLOOD FORMING, NERVOUS, URINARY
& REPRODUCTIVE SYSTEMS(EMBR YOTOXIC EFFECTS). METHYL ETHYL KETONE
MAY INCREASE THE NERVOUS SYSTEM EFFECTS OF OTHER SOLVENTS. (SEE
SUPP)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, UNCONSCIOUSNESS, HEADACHE,
DIZZINESS, NAUSEA, LOSS OF COORDINATION, REDNESS, ITCHING, BURNING
SENSATION, DISCOMFORT, PAIN, CONSTIPATION, LOSS OF APPETITE,
METALLIC TASTE, INSOMNIA, IRRITAB ILITY, WEAKNESS, MUSCLE & JOINT
PAINS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. KEEP WARM
& QUIET. SKIN: WASH AREA THOROUGHLY W/SOAP & WATER. EYES: FLUSH W/
LARGE AMOUNTS OF WATER FOR 15 MINS. OBTAIN MEDICAL ATTENTION IN ALL
CAS ES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:21-35F
Lower Limits:0.9
Upper Limits:12.7
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT & SCBA. WATER
SPRAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE PREFERABLE.
WATER MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. APPLICATION TO HOT SURFACES REQUIRES
SPECIAL PRECAUTIONS. OVEREXPOSURE MAY CAUSE A HEALTH HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION. VENTILATE & REMOVE
W/INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FORM HEAT, SPARKS & OPEN
FLAME. EXTINGUISH ALL OTHER SOURCES OF IGNITION. KEEP CONTAINER
CLOSED WHEN NOT IN USE. KEEP AREA VENTILATED.
Other Precautions:DON'T SMOKE. CONTENTS FLAMMABLE. TRANSFER TO APPROVED
CONTAINERS W/COMPLETE LABELING. DON'T TAKE INTERNALLY. KEEP OUT OF
REACH OF CHILDREN. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING
& INHALINGTHE CONTENTS CAN BE HARMFUL/FATAL.(SUPP)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURE CAN'T BE CONTROLLED BELOW APPLICABLE
LIMITS, WEAR A PROPERLY FITTED ORGANIC VAPOR/PARTICULATE RESPIRATOR
APPROVED BY NIOSH/MSHA. FOR NON-VOLATILE MATERIALS, WEAR A
PARTICULATE RESPIRATOR A PPROVED BY NIOSH/MSHA FOR PROTECTION.
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IS
MAINTAINED BELOW APPLICABLE EXPOSURE LIMITS.
Other Protective Equipment:PERSONAL PROTECTIVE EQUIPMENT TO MINIMIZE
EXPOSURE.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS AFTER USING.
Supplemental Safety and Health
HLTH HZRD CONT'D: OVEREXPOSURE MAY CAUSE ADVERSE EFFECTS TO THE LIVER,
URINARY, BLOOD FORMING, CARDIOVASCULAR & REPRODUCTIVE SYSTEM.
REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT BRA
IN & NERVOUS SYSTEM DAMAGE. PREC CONT'D: KEEP CONTAINERS TIGHTLY
CLOSED. DON'T INCINERATE CLOSED CONTAINER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:174-395F
Vapor Density:>1
Spec Gravity:0.88-1.1
VOC Grams/Liter:5.1
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:MEDIUM YELLOW
Percent Volatiles by Volume:64-90
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, HOT SURFACES,
IGNITION SOURCES.
Hazardous Decomposition Products:BY FIRE: CO2, CO, OXIDES OF METAL.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE/INCINERATE IN APPROVED FACILITY
IAW/FEDERAL, STATE & LOCAL REGULATIONS. WASTE MAY BE HAZARDOUS
UNDER THE RCRA & MUST BE TESTED FOR IGNITABILITY. WASTE CONTAINING
LEAD, CHROMIUM & METHYL ETHYL KETONE MAY REQUIRE TESTING FOR
EXTRACTABILITY.
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ENAMEL, ALKYD, GLOSS, LO VOC CN BLUE 15044, ID 774504
Preparer's Name:W A ELLISON
CAGE:61196
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:N-BUTYL ACETATE (SOLVENT) (VAPOR PRESSURE 10 MM HG @ 20C)
(LFL 1.7; UFL 7.6)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:150 PPM;STEL 200 PPM
ACGIH TLV:150 PPM;STEL 200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENE (SOLVENT) (SARA III) (VAPOR PRESSURE 5 MM HG @ 20C)
(LFL 1.0; UFL 7.0)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM;STEL 150 PPM
ACGIH TLV:100 PPM;STEL 150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL ISOAMYL KETONE (SOLVENT)
CAS:110-12-3
RTECS #:MP3850000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:50 PPM; 240 MG/M3
ACGIH TLV:50 PPM; 240 MG/M3
Ingred Name:SILICA, CRYSTALLINE (PIGMENT)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1000 MG/M3
ACGIH TLV:0.1000 MG/M3
Ingred Name:METHYL ETHYL KETONE (SOLVENT) (SARA III) (VAPOR PRESSURE 70
MM HG @ 20C) (LFL 2.0; UFL 10.0)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM;STEL 300 PPM
ACGIH TLV:200 PPM;STEL 300 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:MINERAL SPIRITS (SOLVENT) (VAPOR PRESSURE 2 MM HG @ 20C)
(LFL: 1.0 UFL: 7.0)
CAS:64475-85-0
RTECS #:PY8240000
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM; 525 MG/M3
ACGIH TLV:100 PPM; 525 MG/M3
Ingred Name:VOC: 2.73 LB/GAL LESS WATER & NEGLIGIBLY PHOTOCHEMICALLY
REACTIVE MATERIALS; 328 G/L LESS WATER; CALCULATED
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:UNKNOWN IARC:YES
Health Hazards Acute and Chronic:INGESTION: GASTROINTESTINAL IRRIT,
NAUSEA, VOMITING. ASPIRATION INTO LUNG MAY CAUSE CHEM PNEUMONITIS
(CAN BE FATAL). INHALATION: NOSE/THROAT IRRIT. ACUTE CENTRAL
NERVOUS SYSTEM DEPRESSION (HEADACHES, DIZZINESS, NAUSEA,
CONFUSION). EYE: SEVERE IRRIT. SKIN: ABSORBED THROUGH SKIN IN
HARMFUL AMTS. DEFATTING & SKIN IRRIT.
Explanation of Carcinogenicity:IARC CONSIDERS CRYSTALLINE SILICA TO
HAVE LIMITED EVIDENCE OF CARCINOGENICITY IN HUMANS & SUFFICIENT IN
ANIMALS.
Effects of Overexposure:CHRONIC; SILICOSIS (DISABLING LUNG DISEASE).
LIVER, KIDNEY AND BLOOD INJURY. ENHANCES NEUROTOXICITY (SYNERGISTIC
EFFECT RESULTED IN PERIPHERAL NEUROPATHY). PROLONGED & REPEATED
OVEREXPOSURE: PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
CONCENTRATING & INHALING PRODUCT MAY BE HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY CONDITIONS
MAY BE AGGRAVATED BY EXPOSURE TO CRYSTALLINE SILICA.
======================= First Aid Measures =======================
First Aid:INGEST: DONT INDUCE VOMITING. CALL POISON CTR/EMERG ROOM/DR
IMMED. INHAL:REMOVE TO FRESH AIR IMMED. IF BREATHING STOPPED, GIVE
ARTIF RESPRTN. KEEP WARM & QUIET. GET MED AID IMMED. EYE: FLUSH
W/WATER 1 5 MIN, LIFTING EYELIDS. GET MED AID. SKIN: REMOVE CONTAM
CLOTHES. WASH AFFECTED AREA W/SOAP & WATER. GET MED AID IF IRRIT
PERSISTS. NOTE TO DR:DIRECT TREATMENT AT CLINICAL CONDITION &
SYMPTOM CONTROL.
===================== Fire Fighting Measures =====================
Flash Point:24.0F,-4.4C
Autoignition Temp:Autoignition Temp Text:572 F
Lower Limits:1.0
Upper Limits:10.0
Extinguishing Media:NFPA CLASS B EXTINGUISHERS (CO2, DRY CHEMICAL,
ALCOHOL FOAM) FOR FLAMMABLE LIQ. POLYMER FOAM PREFERRED FOR LARGE
FIRES.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE, USE TO COOL EXPOSED
CONTAINERS (FOG NOZZLES PREFERRED) TO PREVENT PRESSURE BUILDUP,
AUTOIGNITION OR EXPLOSION WHEN EXPOSED TO HEAT.
Unusual Fire/Explosion Hazard:DURING EMERGENCY CONDITIONS, OVEREXPOSURE
TO DECOMPOSITION PRODUCTS MAY BE HEALTH HAZARD. SYMPTOMS MAY NOT BE
IMMEDIATELY APPARENT. GET MEDICAL AID. FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP SPECTATORS AWAY. ELIMINATE ALL IGNITION
SOURCES. DIKE & CONTAIN WITH INERT MATERIAL (SAND, EARTH, ETC).
TRANSFER LIQUID OR USED ABSORBENT TO COVERED METAL CONTAINER. USE
NON-SPARKING TOOLS. PREVE NT SEWER, STREAM, OR GROUNDWATER
CONTAMINATION.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 115 F. STORE LARGE
QUANTITIES IN COMPLIANCE WITH OSHA 29 CFR 1910.106. DO NOT TAKE
INTERNALLY. DO NOT BREATHE SANDING DUST.
Other Precautions:CLOSE CONTAINER AFTER EACH USE. DO NOT WASH & REUSE
EMPTY CONTAINER FOR ANY PURPOSE. GROUND & BOND CONTAINERS TO
RECEIVING CONTAINER. DO NOT WELD, BRAZE, OR CUT ON EMPTY CONTAINER.
NEVER USE PRESSURETO EMPTY. DRUM IS NOT A PRESSURE VESSEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTD,MAY NOT REQ RSPRTR.IN RESTRICTD
VENT,NIOSH CHEM CARTRIDGE RSPRTR MAY BE REQ'D.SPRAYNG,MECHAN
PREFILTER MAY ALSO BE REQ'D.CONFIND AREAS,USE AIR SUPPLD RSPRTR.SEE
OSHA 29CFR1910.134"RESP PROTEC T"&"RESP PROTECT-MANUAL &
GUIDELINE"AIHA
Ventilation:LOCAL EXHAUST VENT TO KEEP BELOW TLV. REMOVE DECOMPOSITION
PRODUCT. SEE "INDUST VENT-MANUAL RECOMMENDED PRACTICES" ACGIH
Other Protective Equipment:NOT LIKELY TO BE NEEDED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:175 TO 388F
Melt/Freeze Pt:M.P/F.P Text:-50F,-46C
Decomp Temp:Decomp Text:1832F,1000C
Vapor Pres:70 @ 68F
Vapor Density:> AIR
Spec Gravity:1.0
pH:4-7
Viscosity:67 - 77 KU
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Solubility in Water:SLIGHT IN WATER
Appearance and Odor:LIQUID, SOLVENT ODOR
Percent Volatiles by Volume:38
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS. OXIDIZING MATERIALS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT (>115F) AND SOURCES
OF IGNITION.
Hazardous Decomposition Products:BURNING, INCLUDING WHEN HEATED BY
WELDING OR CUTTING, WILL PRODUCE SMOKE, CARBON MONOXIDE & CARBON
DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE, &
LOCAL LAWS OR REGULATIONS. THIS PRODUCT, IF DISCARDED DIRECTLY,
WOULD BE CLASSIFIED A HAZARDOUS WASTE BASED ON ITS IGNITABILITY
CHARACTERISTIC (FLASH POINT 140F OR LESS). PROPER RCRA
CLASSIFICATION: D001.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:VV-D-1078B 12,500 C/S
CAGE:56921
CAGE:56921
============= Composition/Information on Ingredients =============
Ingred Name:POLYDIMETHYLSILOXANE
CAS:9016-00-6
RTECS #:TQ2690000
Fraction by Wt: 100%
===================== Hazards Identification =====================
Effects of Overexposure:PER MFR NON TOXIC NON-IRRITATING:MAY CAUSE
DISCOMFORT OR IRRITATION TO EYES AND SKIN
======================= First Aid Measures =======================
First Aid:INHALE:REMOVE TO FRESH AIR, GIVE CPR/O*2 IF
NEED;EYES/SKIN:FLUSH W LG AMTS H*2O FOR 15 MIN;INGEST:RINSE MOUTH;
GET MEDICAL ATTENTION FOR EYES, BREATHING DIFFICULTY, OR OTHER
SYMPTOMS OF OVEREXPOSURE.
===================== Fire Fighting Measures =====================
Flash Point:<535F/279C(COC)
Extinguishing Media:CO*2, FOAM, DRY CHEM & H*2O FOG.
Fire Fighting Procedures:WATER MAY CAUSE FROTHING.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP UP GROSS QUANTITIES:COVER OR POWDER WITH
A DRY POWDER,BRUSH BACK & FORTH.SWEEP UP. REMOVE REMAINING DUST OR
POWDER WITH A SAWDUST-TYPE SWEEPING COMPOUND.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:CLEAN UP SPILLS COMPLETELY AS RESIDUE IS SLIPPERY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL REQMNTS UNDER ORDINARY
CONDITIONS/ADEQUATE VENT.
Ventilation:NO SPECIAL REQUIREMENTS W ADEQUATE VENT.
Other Protective Equipment:AS REQUIRED TO PREVENT PROLONGED CONTACT.
Supplemental Safety and Health
MSDS UNDATED.
================== Physical/Chemical Properties ==================
HCC:V6
Vapor Pres:<1
Spec Gravity:0.965
Evaporation Rate & Reference:NIL
Solubility in Water:NEG
Appearance and Odor:CLEAR,COLORLESS,ODORLESS LIQUID.
Percent Volatiles by Volume:NEGL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATION IS BEST. OPEN BURNING IS
SATISFACTORY IF A WHITE SMOKE IS NOT OBJECTIONABLE.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CAVICLEAN 2
CAGE:61102
CAGE:61102
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2-BUTOXY-; (2-BUTOXYETHANOL) (SARA III)
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: <5%
OSHA PEL:50 PPM, S
ACGIH TLV:25 PPM, S
Ingred Name:SODIUM SILICATE
CAS:1344-09-8
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:NITROUS ACID, SODIUM SALT; (SODIUM NITRITE) (SARA III)
CAS:7632-00-0
RTECS #:RA1225000
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:BENZENESULFONIC ACID, DODECYL-, SODIUM SALT; (SODIUM
DODECYLBENZENE SULFONATE) (SARA III)
CAS:25155-30-0
RTECS #:DB6825000
Fraction by Wt: 10%
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:SPENT SOLN & RINSE WATER MAY BE TREATED BY
NEUTRALIZING, ALLOWING TO STAND & SKIMMING OFF SEPARATED SOLV &(ING
7)
RTECS #:9999999ZZ
Ingred Name:ING 6:SOIL. NITRITE MAY BE REMOVED BY ADDING 50% EXCESS OF
AMMONIA FOLLOWED BY PH ADJUSTMENT TO 1. WHEN NITROGEN (ING 8
RTECS #:9999999ZZ
Ingred Name:ING 7:EVOLUTION (BUBBLING) HAS STOPPED, READJUST PH TO 7-8.
RESIDUAL ORGANIC MATTER MAY BE REMOVED BY OXIDATION (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:&/OR CARBON TREATMENT. CLARIFIED RINSE WATER MAY BE
RELS TO SEWER IF LOC REGS PERMIT.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:OPENINGS TO AVOID SPURTING. CLEAN EXTERIOR &
INTERIOR BY FLUSHING W/WATER. COLLECT FLUSHINGS FOR (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:DISPOSAL. USE PROTECTIVE EQUIPMENT FOR EYES, SKIN &
INHALATION.
RTECS #:9999999ZZ
Ingred Name:EYE PROT:& FULL LENGTH FACE SHIELD .
RTECS #:9999999ZZ
Ingred Name:OTHER PROT EQUIP:PROLONGED OR REPEATED SKIN CONTACT OR
OTHER EXPOSURE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:CONT MAY CAUSE MOD TO SEV IRRIT,
POSS BURNS. SKIN:CONT MAY CAUSE MOD TO SEV IRRIT. INHAL:INHAL OF
MIST FROM SOLN MAY CAUSE MOD TO SEV IRRIT OF RESP TRACT. INGEST:MOD
TO SEV IRRIT OF GI TRACT. INGE ST OF SIGNIFICANT AMTS MAY RSLT IN
ACUTE TOX EFTS & MAY BE FATAL. INGEST OF SIGNIFICANT AMTS OF SODIUM
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:NITRITE MAY CAUSE CONVERSION OF
HEMOGLOBIN TO METHEMOGLOBIN, PRDCG CYANOSIS, BLOOD PRESS DROP, POSS
COLLAPSE, COMA/DEATH. ANIMAL STUDIES CLEARLY DEMONSTRATED
DOSE-RELATED ADVERSE EFTS ON CNS, HEMATOPOIETIC TISS, BLOOD,
KIDNEYS & LIVER, ASSOC W/ADMIN OF ETHYLENE GLYCOL MONOBUTYL ETHER
(EGBE). (EXTRACTED(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/LG VOLS OF WATER FOR AT LST 15 MINS. IF IRRIT
PERSISTS, OBTAIN MED ATTN. SKIN:FLUSH AFFECTED AREA W/LG VOLS OF
WATER. CONTINUE FLUSHING AT LST 15 MINS. IF IRRIT IS
EVID/BLISTERING OCCURS, OBTAIN MED ATTN. INHAL:REMOVE TO FRESH
AIR. ADMIN OXYGEN IF BRTHG IS DFCLT. OBTAIN MED ATTN IF IRRIT
PERSISTS. INGEST:DO NOT INDUCE VOMIT EXCEPT ON ADVICE OF COMPETENT
MED PERS. IF VICTIM IS (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:CONFINE SPILL. STOP LEAK AT SOURCE IF THIS CAN
BE DONE SAFELY. VENTILATE AREA. PUMP LIQ INTO DRUMS FOR DISP.
ABSORB REMAINING LIQ ONTO INERT ABSORB & PLACE IN SEALABLE CNTNRS
FOR DISP. WASH AREA W/WAT ER. COLLECT WASHING IN DRUMS. SPENT SOLN
&(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN DRY PROTECTED AREA.
NOTE:UNDER CERTAIN CNDTNS, NITRITES MAY REACT W/SECONDARY AMINES TO
FORM POTNTLY CARCINOGENIC NITROSAMINES.
Other Precautions:CAREFULLY ADD TO WATER WHILE MIXING, TAKING CARE TO
AVOID SPLASHING. USE APPROP SFTY EQUIP TO ELIM POSS OF SKIN/EYE
CONT. MAKE ADDNS TO IN-USE TANKS SLOWLY & CAUTIOUSLY. REPAIR &
MAINT OF CONTAM EQUIP : RELIEVE ANY PRESS. COVER (ING 10)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR MIST CONDITIONS, A NIOSH/MSHA APPROVED
RESPIRATOR FOR TOXIC DUSTS & MISTS IS ADVISED. IF RESPIRATORS ARE
USED, A FORMAL TRAINING & SCREENING PROGRAM MUST BE INITIATED. SEE
29 CFR 1910.134.
Ventilation:MAINTAIN SUFFICIENT MECHANICAL VENTILATION TO KEEP VAPOR
CONCENTRATION BELOW TLV.
Other Protective Equipment:BOOTS & APRONS MADE OF NEOPRENE/OTHER
IMPERVIOUS MATL. PROT SUIT NOT NORMALLY REQD, BUT ADVISED IF NEC TO
AVOID (ING 13)
Work Hygienic Practices:WASH HANDS & FACE W/SOAP & WATER BEFORE
SMOKING/EATING. IMMED REMOVE ALL CONTAM CLTHG. LAUNDER SEPARATELY
BEFORE REUSE.
Supplemental Safety and Health
PH:12(CONCENTRATED). EFTS OF OVEREXP:FROM DHHS (NIOSH) PUBLICATION
NO.90-118) . FIRST AID PROC:CONSCIOUS, DILUTE BY GIVING LG VOLS OF
MILK/WATER. OBTAIN IMMED MED ATTN. IF CYANOSIS DEVELOPS, GIV E
OXYGEN. NEVER ATTEMPT TO INDUCE VOMIT/GIVE ANYTHING BY MOUTH TO
UNCON PERS. SPILL PROC:RINSES:DISP AS ABOVE/ (ING 6)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:20
Vapor Density:<1
Spec Gravity:1.05
pH:SUPDAT
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, AMBER LIQUID; SLIGHT AMMONIA ODOR.
Percent Volatiles by Volume:74
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONT W/STRONG ACIDS, AMINES/REDUCING AGENTS, ESP CYANIDES, THIOCYANATES
& THIOSULFATES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:TRANSFER TO RECLAIMING CENTER FOR RECYCLING OR
REUSE, IF POSSIBLE. TRANSFER TO LICENSED WASTE TREATMENT OR
DISPOSAL SITE FOR DISPOSITION UNDER APPLICABLE LOCAL, STATE,
REGIONAL & FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CARGILL KINGSBURY-CLARK ALBUMIN STDS, 20 MG
CAGE:IO084
CAGE:10684
CAGE:IO084
============= Composition/Information on Ingredients =============
Ingred Name:FORMALDEHYDE (SARA III)
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: .30%
OSHA PEL:1 PPM;2 PPM STEL
ACGIH TLV:0.3 PPM A2, C
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:NONE KNOWN AT C.I.U. IF TUBES ARE
BROKEN OPEN, FORMALDEHYDE (O.3% OF GEL BY WEIGHT) VAPORS MAY
IRRITATE EYES AND NOSE. CONTACT MAY IRRITATE SKIN OR EYES.
INGESTION MAY IRRITATE MOUTH AND STOMACH.
Explanation of Carcinogenicity:FORMALDEHYDE:IARC MONOGRAPHS,
SUPPLEMENT, VOL.7, PG 211, 1987:GRP 2A. NTP 6TH ANNUAL RPT ON
CARCIN ANTIC TO BE CARCIN.
Effects of Overexposure:TUBES BROKEN OPEN; SLIPPERY GEL ON CLOTHES OR
BODY; IRRITATION OF EXPOSED AREA OF BODY.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INCLUDE POSSIBLE MATERIAL THAT MAY HAVE BEEN MIXED WITH
LIQUID DURING USE. INHAL:REMOVE TO FRESH AIR. SKIN:WASH WITH SOAP
AND WATER. EYES:FLUSH WITH WATER FOR AT LEAST 15 MINUTES-CONTACT
PHYSICIAN. IN GEST:CONTACT PHYSICIAN; IF CONSCIOUS, GIVE LARGE
AMOUNTS OF WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:122F,50C
Extinguishing Media:CARBON DIOXIDE
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB, PLACE IN PLASTIC CONTAINER, CAP OR
TWIST TIE CLOSURE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREAKING TUBES; MINIMIZE
EXPOSURE TO LIGHT, ESPECIALLY DIRECT SUN. STORE BETWEEN 50 AND 85
F.
Other Precautions:AVOID VAPORS, PROLONGED AND REPEATED SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NOT MANDATORY EXCEPT AS GOOD LABORATORY INDUSTRIAL
PRACTICES.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:ALWAYS USE GOOD HYGENIC WORK/PRACT. AS TO
HOUSEKEEPING, PERS HYGIENE, USE OF CHEM LAB APRON AND SPLASH
Supplemental Safety and Health
APPEAR/ODOR:CHARACTERISTIC ODOR IF OPENED.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:140F,60C
Vapor Pres:<24
Spec Gravity:1.16
Evaporation Rate & Reference:<1
Solubility in Water:VIRTUALLY COMPLETE
Appearance and Odor:VERY LIGHT TAN GEL SEALED IN GLASS TUBES W/EPOSY &
NATURAL CORK.SLIGHT(SUPPDATA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Conditions to Avoid Polymerization:HEAT, FLAME, SOURCES OF IGNITION,
POLYMERIZATION UNLIKELY AT CONCENTRATION USED.
==================== Disposal Considerations ====================
Waste Disposal Methods:ALL CHEMICAL DISPOSAL MUST BE IN ACCORDANCE WITH
LOCAL, STATE, AND FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:NORTRON EC
CAGE:5Y558
CAGE:5Y558
============= Composition/Information on Ingredients =============
Ingred Name:ETHOFUMESATE, CAS 26225-79-6
CAS:26225-79-6
RTECS #:DF7716500
Fraction by Wt: 19%.
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 58%.
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:CYCLOHEXANONE (SARA III)
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: 15%.
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:EYE,SKN:IRRT. INHL, INGEST:WEAKNESS, LOSS
COORDINATION, NARCOSIS.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH 15 MIN W/AMPLE WATER.SKN:WASH SOAP & WATER.
INHL:REMOVE TO FRESH AIR, GIVE O*2 OR ART RESP AS REQUIRED.
INGEST:DO NOT INDUCE VOMIT, GIVE DEMULCENT:MILK, EGGWHITES, GELATIN
SOLN, WATER. AVOIDALCOHOL. IF UNCONSC GIVE NOTHING. CALLPHYS
IMMED
===================== Fire Fighting Measures =====================
Flash Point:85F/29C PMCC
Extinguishing Media:DRY POWDER, FOAM, WATER
Fire Fighting Procedures:USE SCBA PP MODE. AVOID INHL FUMES OR VAPOR
Unusual Fire/Explosion Hazard:HIGHLY FLAMMABLE LIQUID
================== Accidental Release Measures ==================
Spill Release Procedures:USE CCROV, BODY PROTECTION. DIKE SPILL, SCOOP
OR SHOVEL INTO CLOSABLE CONTAINER. COLLECT REMAINING SPILLAGE
W/ABSORBENT, PLACE IN CLOSABLE CONTAINER. DO NOT ALLOW SPILLAGE TO
REACH SEWERS OR WATERWAYS .
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY AREA, AWAY FROM
HEAT & IGNITION SOURCES.
Other Precautions:AVOID EYE, SKN CONTACT. DO NOT INHAL OR INGEST. KEEP
AWAY FROM FOODSTUFFS, ANIMALS, CHILDREN WHEN USING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE CCROV RESPIRATOR AS REQD.
Ventilation:LOCAL OR GENERAL MECHANICAL
Other Protective Equipment:OVERALLS, BOOTS
Supplemental Safety and Health
NON-STD MSDS DATED 27MAY85. EPA REGIS NO:45639-68
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:300F (EST)
Vapor Pres:NEG
Spec Gravity:0.95
Solubility in Water:EMULSIFIES
Appearance and Odor:STRAW COLORED LIQUID, AROMATIC HYDROCARBON ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS
Stability Condition to Avoid:EXCESS HEAT, IGNITION SOURCES
Hazardous Decomposition Products:CARBON OXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:RECLAIM OR INCINERATE IAW ALL LAWS & REGS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SOY-165, BIONOMIC SERIES INKS, PANTONE 165 ORANGE
CAGE:0FTL5
CAGE:0FTL5
CAGE:09177
============= Composition/Information on Ingredients =============
Ingred Name:BLUE PIGMENT; (PHTHALO BLUE). CONTAINS ING #2.
CAS:147-14-8
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:COPPER (SARA III)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 14%
OSHA PEL:0.1 MG/M3;1 DUST
ACGIH TLV:0.2 MG/M3;1 DUST
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: SKIN. EYES:CONTACT MAY
CAUSE BURNING & IRRITATION. SKIN:PROLONGED OR REPEATED EXPOSURE MAY
CAUSE IRRITATION OR DERMATITIS. INHAL:EXCESSIVE INHALATION OF
VAPORS MAY CAUSE HEADACHE, DIZZI NESS, DROWSINESS & NAUSEA.
INGEST:MAY CAUSE IRRITATION OR GASTRIC DISTURBANCE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:EYES:RINSE THOROUGHLY W/WATER FOR AT LEAST 15 MINS. IF
IRRITATION PERSISTS, CONSULT MD. SKIN:WASH W/MILD SOAP & WATER.
INHAL:REMOVE TO FRESH AIR. APPLY ARTIFICIAL RESPIRATION &/OR OXYGEN
IF NEEDED. CO NSULT MD. INGEST:DO NOT INDUCE VOMITING. SEEK MEDICAL
AID.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:215F,102C
Extinguishing Media:FOAM, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . WATER CAN BE USED TO KEEP MATERIAL COOL.
Unusual Fire/Explosion Hazard:DENSE SMOKE MAY BE GENERATED WHILE
BURNING.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP SPILLS W/RAGS. DISPOSE OF RAGS IN
CONTAINER APPROVED FOR OILY WASTE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE. KEEP AWAY FROM EXCESSIVE HEAT, SPARKS & OPEN FLAME.
Other Precautions:DO NOT REUSE CONTAINER. FOR COMMERCIAL & INDUSTRIAL
USE ONLY. KEEP FROM REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED. NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:GENERAL VENTILATION AS PER LOCAL OR STATE REGULATIONS.
Other Protective Equipment:APRON, FOOTWEAR & IMPERVIOUS CLTHG AS NEEDED
TO PVNT EXCESSIVE SKIN CONTACT. EMERGENCY EYEWASH & DELUGE SHOWER .
Work Hygienic Practices:WASH HANDS & FACE W/SOAP & WATER BEFORE EATING
OR SMOKING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>550F,>288C
Vapor Density:GREATER
Spec Gravity:<1 (H*2O=1)
Evaporation Rate & Reference:SLOWER (BUTYL ACETATE=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORED PASTE; OILY ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONTACT W/STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESS HEAT.
Hazardous Decomposition Products:DENSE SMOKE, CARBON MONOXIDE & CARBON
DIOXIDE WHEN BURNING.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE W/LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:TT-E-2784
Preparer's Name:ONEY FLEMING
CAGE:EO326
CAGE:EO326
CAGE:39934
============= Composition/Information on Ingredients =============
Ingred Name:EKTASOLVE EEH SOLVENT
CAS:1559-35-9
RTECS #:KK9625000
Fraction by Wt: 3.32%
Other REC Limits:NONE RECOMMENDED
Ingred Name:BENZYL ALCOHOL
CAS:100-51-6
RTECS #:DN3150000
Fraction by Wt: 3.32%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIMETHYLAMINOETHANOL LOW VOE
CAS:108-01-0
RTECS #:KK6125000
Fraction by Wt: 0.38%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: 92.98%
Other REC Limits:NONE RECOMMENDED
Ingred Name:VOC: 1.8 LB/GL; 211 G/LTR
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CAN CAUSE IRRITATION OF RESPIRATORY
PASSAGES.
Effects of Overexposure:INHALATION OF VAPOR OR MIST CAN CAUSE
HEADACHES, NAUSEA, IRRITATION OF NOSE, THROAT, AND LUNGS. EYE
CONTACT CAN CAUSE SLIGHT IRRITATION. PROLONGED OR REPEATED SKIN
CONTACT CAN CAUSE SLIGHT IRRITATION.
Medical Cond Aggravated by Exposure:PRE-EXISTING LUNG DISEASE MAY BE
AGGRAVATED BY EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYE CONTACT: FLUSH WITH LARGE AMOUNTS OF WATER FOR 15
MINUTES, CONSULT PHYSICIAN IF IRRITATION PERSISTS. SKIN CONTACT:
WASH AFFECTED AREA THOROUGHLY WITH SOAP AND WATER. INGESTION: IF
SWALLOWED, GIVE 2 GLASSES OF WATER TO DRINK, CONSULT PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>212F,>100C
Autoignition Temp:Autoignition Temp Text:216 F
Lower Limits:NONE
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS
(PRESSURE DEMAND MSHA/NIOSH APPROVED OR EQUIVALENT) AND FULL
PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:MATERIAL CAN SPLATTER ABOVE 100C. POLYMER
FILM CAN BURN.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP SPECTATORS AWAY. FLOOR MAY BE SLIPPERY,
USE CARE TO AVOID FALLING. CONTAIN SPILLS WITH INERT MATERIALS
(SAND, EARTH). TRANSFER LIQUIDS AND SOLID DIKING MATERIAL TO
SEPARATE SUITABLE CONTAINERS FO R RECOVERY/DISPOSAL.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING.
Other Precautions:DO NOT TAKE INTERNALLY. KEEP AWAY FROM CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:APPROVED MECHANICAL FILTER RESPIRATOR TO REMOVE
SOLID AIRBORNE PARTICLES OF OVER SPRAY DURING SPRAY APPLICATION.
Ventilation:NORMAL, SUCH AS A FAN
Other Protective Equipment:EYE WASH STATION.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212 TO 644F
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Decomp Temp:Decomp Text:350F,177C
Vapor Pres:NONE
Vapor Density:> AIR
Spec Gravity:1.01 (WATER=1)
pH:9 MAX
Viscosity:77-95 KU
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT
Appearance and Odor:GREEN LIQUID WITH SLIGHT ODOR
Percent Volatiles by Volume:60.6
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
THERE ARE NO KNOWN MATERIALS WHICH ARE INCOMPATIBLE WITH THIS PRODUCT.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD
ACRYLIC MONOMERS.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP SPILLS AND CLEANING RUN-OFF OUT OF
MUNICIPAL SEWERS AND OPEN BODIES OF WATER. CONSULT FEDERAL, STATE,
OR LOCAL AUTHORITIES FOR PROPER DISPOSAL PROCEDURES CONCERNING
HEALTH AND ENVIRONMENT.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:FORMULA 15282, 5348
CAGE:72674
CAGE:27674
CAGE:72674
============= Composition/Information on Ingredients =============
Ingred Name:SILICIC ACID (H*2SIO*3) DISODIUM SALT; (SODIUM
METASILICATE)
CAS:6834-92-0
RTECS #:VV9275000
Fraction by Wt: 20-30%
OSHA PEL:2MG/M3 (PWDR) (MFR)
ACGIH TLV:2MG/M3 (PWDR) (MFR)
Ingred Name:SODIUM CARBONATE (2:1)
CAS:497-19-8
RTECS #:VZ4050000
Fraction by Wt: 10-20%
OSHA PEL:15MG/M3 DUST (MFR)
ACGIH TLV:15MG/M3 DUST (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CORROSIVE TO SKIN AND EYES. THE
AMOUNT OF TISSUE DAMAGE DEPENDS ON LENGTH OF CONTACT. EYE CONTACT
CAN RESULT IN CORNEAL DAMAGE OR BLINDNESS. SKIN CONTACT CAN PRODUCE
INFLAMMATION AND BLISTERING . INHALATION OF DUST WILL PRODUCE
IRRITTO GASTROINTESTINAL OR RESPIRATORY TRACT, CHARACTERIZED(SEE
EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:BY BURNING, SNEEZING & COUGHING.
SEVERE OVER-EXPOS CAN PRODUCE LUNG DMG, CHOKING, UNCON/DEATH.
CHRONIC:RPTD EXPOS OF EYES TO LOW LEVEL OF DUST CAN PRODUCE EYE
IRRIT. RPTD SKIN EXPOS CAN PRODU CE LOCAL SKIN DESTRUCTION OR DERM.
RPTDINHAL OF DUST CAN PRDC VARYING DEGREES OF RESP IRRIT/LUNG DMG.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN:IMMED FLUSH CONTAM SKIN W/PLENTY OF H20 FOR AT LEAST 15
MINS. GET MD IMMED.EYES:IMMED FLUSH W/PLENTY OF H20 FOR AT LEAST 15
MINS, OCCASNLY LIFTING UPPER & LOWER LIDS. GET MD AT ONCE.
INHAL:MOVE V ICTIM TO FRESH AIR. FLUSH MOUTH AND NASAL PASSAGES
WITH H20 RPTD. GET MD IF IRRIT PERSISTS. INGEST:IF PRODUCT IS
SWALLOWED, DO NOT INDUCE VOMIT. IF VICTIM IS CONSCIOUS GIVE PLENTY
OF H20. GET MD.
===================== Fire Fighting Measures =====================
Extinguishing Media:NON-COMBUSTIBLE. MEDIA SUITABLE FOR SURROUNDING
FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP SPILLED MATERIAL AND PLACE IN A
SUITABLE WASTE CONTAINER. WASH AREA THOROUGHLY WITH A DETERGENT
SOLUTION AND RINSE AREA WELL WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE TIGHTLY CLOSED CONTAINER IN A
DRY AREA AT TEMPERATURES BETWEEN 40F-120F. STORE AWAY FROM STRONG
ACIDS & OXIDIZING COMPOUNDS.
Other Precautions:KEEP PRODUCT AWAY FROM SKIN AND EYES. DO NOT BREATHE
DUST. CLOTHING OR SHOES WHICH BECOME CONTAMINATED WITH SUBSTANCE
SHOULD BE REMOVED PROMPTLY AND NOT REWORN UNTIL THOROUGHLY CLEANED.
KEEP OUT OF TH E REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED DUST MASK IF DUST IS
PRESENT.
Ventilation:IF DUST IS DETECTED, VENTILATE WORK AREA BY OPENING WINDOWS
AND USING EXHAUST FANS.
Other Protective Equipment:ALKALI RESISTANT FOOTWEAR, APRON, AND ARM
COVERING. EMERGENCY EYE WASH & DELUGE SHOWER .
WHEN WEARING CONTACTS.
Supplemental Safety and Health
PH: CONCENTRATE-N/A; DILUTION OF 1% SOLUTION 11.8-12.3. WASTE DISP
METH: CONSULT LOCAL, STATE, AND FEDERAL AGENCIES FOR PROPER METHOD
OF DISPOSAL IN YOUR AREA. EYE PROT: ADD FULL LENGTH FACESHIELD TO
================== Physical/Chemical Properties ==================
HCC:B3
pH:SUPDAT
Solubility in Water:1 1/2 LB/GAL
Appearance and Odor:MOIST, TAN POWDER WITH A MILD AROMA.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:UNUSABLE MATERIAL SHOULD BE DRUMMED AND TAKEN TO
A CHEMICAL OR INDUSTRIAL LANDFILL, OR IF PERMITTED PUT INTO
SOLUTION WITH WATER AND FLUSH INTO A SANITARY SEWER. NEUTRALIZATION
OF PH MAY BE A PREREQUI SITE FOR SEWER DISPOSAL. (SUPP DATA)
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:PREMIUM INTERIOR ALKYD SEMI-GLOSS PAINT, 63.075
CAGE:WATTL
CAGE:WATTL
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT VP: 2 MM HG
CAS:8052-41-3
RTECS #:WJ8925000
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9495
Ingred Name:ALIPHATIC PETROLEUM DISTILLATE. VP: 0.05 MM HG
OSHA PEL:100 PPM (MFR)
ACGIH TLV:500 PPM (MFR)
Ingred Name:SUPDAT:OTHER PREC SECTION SHOULD BE CAREFULLY OBSERVED &
NIOSH/MSHA APPRVD RESPIRATORS SHOULD ALSO BE USED IF (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:THE DRY COATING IS SANDED OR ABRADED IN SUCH A WAY AS
TO PRODUCE DUST.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:ANY TLV LISTED IN ING SECTION MAY BE EXCEEDED.
USE APPROVED RESPIRATOR WITH EXTERNAL AIR SUPPLY.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION: ANESTHETIC.
IRRITATION OF THE RESPIRATORY TRACT, OR ACUTE NERVOUS SYSTEM
DEPRESSION CHARACTERIZED BY THE FOLLOWING PROGRESSIVE STEPS:
HEADACHE, DIZZINESS, STAGGERING GAIT, CONFUSION, UNCONSCIOUSNESS
OR COMA. SKIN OR EYE CONTACT: PRIMARY IRRITATION. CHRONIC: MAY
CAUSE RESPIRATORY AND/OR(EFT OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: SKIN SENSITIZATION. PERMANENT CENTRAL
NERVOUS SYSTEM CHANGES DUE TO SOLVENT OVEREXPOSURE HAVE BEEN
REPORTED.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOS. RESTORE BREATHING. TREAT
SYMPTOMATICALLY. CONSULT MD. EYES:FLUSH IMMED W/LRG AMTS OF H*2O
FOR AT LEAST 15 MIN. TAKE TO MD FOR MEDICAL TREATMENT. SKIN:WASH
AFFECTED AREAS OF SK IN W/SOAP & H*2O. REMOVE DRENCHED CLTHG.
CONSULT MD IF IRRIT PERSISTS. INGEST:DRINK ONE OR TWO GLASSES OF
H*2O TO DILUTE. DO NOT INDUCE VOMIT. CONSULT MD/POIS CTL CTR AT
ONCE. TREAT SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point:100F,38C
Lower Limits:1.0%
Extinguishing Media:USE NATIONAL FIRE PROTECTION ASSOCIATION (NFPA)
CLASS B EXTING/EXTINGUISHING AGENT DESIGNED TO EXTING FLAM LIQ
FIRES.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPARKS & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. APPLICATN TO HOT (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION (FLAME, HOT
SURFACES, AND ELECTRICAL, STATIC OR FRICTIONAL SPARKS). AVOID
BREATHING VAPORS. VENTILATE AREA. CONTAIN AND REMOVE WITH INERT
ABSORBENT AND NON-SPARKING TOOL S.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. STORE LARGE
QUANTITIES ONLY IN BUILDINGS DESIGNED TO COMPLY WITH OSHA 1910.106.
CLOSE CONTAINER AFTER EACH USE.
Other Precautions:DO NOT TAKE INTERNALLY. OBSERVE GOOD SANITARY
PRACTICES. NOTE:PIGMENTED PAINTS & COATING (THOSE WHICH ARE OPAQUE,
COLORED/WHICH HAVE REDUCED GLOSS WHEN DRY) MAY CNTN MATLS SUCH AS
SILICA, TALC, CALCIU M CARBONATE, TITANIUM DIOXIDE, (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF SPRAYED IN AREAS W/UNRESTRICTED VENT, USE
NIOSH/MSHA APPRVD MECH FILTER TO REMOVE OVERSPRAY; IN RESTRICTED
AREAS USE APPRVD CHEM/MECH FILTER TO REMOVE BOTH PARTICLES & VAP.
FOR ANY METH OF APPLICAT ION IN CONFINED AREAS WHERE (ING 5)
Ventilation:PROVIDE SUFFICIENT VENT, IN VOLUME & PATTERN, TO INSURE VAP
CONC WELL BELOW ANY TLV & LEL LISTED IN ING SECTIONS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ:SURF REQ SPEC PREC. DURING EMER SITUATIONS OVER-EXPOS TO
DECOMP PROD MAY CAUSE HLTH HAZ. SYMP MAY NOT BE IMMED APPARENT.
OBTAIN MED ATTN. OTHER PREC:ETC, WHICH ARE HAZ TO INHALE IN DRY
POWDE R FORM. THESE HAZ ARE NOT BELIVED TO BEPRESENT WHEN POWDERS
ARE DISPERSED IN LIQ COATINGS. HOWEVER, PREC IN (ING 3)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.08-1.29
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:57-61
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:WHEN HEATED TO DECOMPOSITION, AS IN A
FIRE OR IN WELDING, MAY PRODUCE TOXIC FUMES SUCH AS CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSE CONTAINERS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:GASKET SEALANT NO. 1, CDA 150
Preparer's Name:JAY TATE
CAGE:CLEME
CAGE:CLEME
CAGE:6Z186
============= Composition/Information on Ingredients =============
Ingred Name:CLAY
CAS:1332-58-7
RTECS #:GF1670500
Fraction by Wt: 50-55%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ROSIN
CAS:8050-09-7
Fraction by Wt: 20-25%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ISOPROPYL ALCOHOL
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 10-15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:400 PPM;STEL 500 PPM
ACGIH TLV:400 PPM;STEL 500 PPM
Ingred Name:VEGETABLE OIL
CAS:68439-93-0
Fraction by Wt: 5-10%
Other REC Limits:* 5 MG/M3(MIST RESP)
OSHA PEL:15 MG/M3(MIST DUST)*
ACGIH TLV:10 MG/M3 (MIST)
Ingred Name:SOYBEAN DERIVATIVE
CAS:8002-43-5
Fraction by Wt: 1-3%
Other REC Limits:NONE RECOMMENDED
Ingred Name:IRON OXIDE
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 0.1-0.5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:VOLATILE ORGANIC COMPOUND (EPA METHOD 24): 231 GRAMS PER
LITER
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:MODERATELY TOXIC BY INGESTION. EYE
IRRITANT.
Effects of Overexposure:VAPOR ABOVE TLV IS IRRITATING TO EYES, NOSE,
AND THROAT AND CAN CAUSE HEADACHE, DIZZINESS, NAUSEA
Medical Cond Aggravated by Exposure:SKIN, EYE, AND RESPIRATORY
DISORDERS.
======================= First Aid Measures =======================
First Aid:INGESTION: INDUCE VOMITING. OBTAIN MEDICAL ATTENTION.
INHALATION: REMOVE TO FRESH AIR. IF SYMPTOMS PERSIST, OBTAIN
MEDICAL ATTENTION. SKIN CONTACT: WASH WITH SOAP AND WATER. EYE
CONTACT: FLUSH AT LEAS T 15 MINUTES WITH WATER. OBTAIN
MEDICALATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:60.0F,15.6C
Lower Limits:2
Upper Limits:12
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL
Unusual Fire/Explosion Hazard:FORMS IRRITATING ORGANIC VAPORS BY FIRE
OR THERMAL DECOMPOSITION.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION. MAINTAIN ADEQUATE
VENTILATION. SCRAPE UP AS MUCH AS POSSIBLE AND STORE IN A CLOSED
CONTAINERS UNTIL DISPOSAL. RESIDUE MAY CLEANED WITH ISPROPYL
ALCOHOL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HEAT AND FLAME.
Other Precautions:AVOID PROLONGED BREATHING OF VAPORS. KEEP AWAY FROM
EYES.
============= Exposure Controls/Personal Protection =============
Ventilation:MUST BE ADEQUATE TO AVOID EXCEEDING TLV.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:180F,82C
Vapor Pres:33 @ 68F
Vapor Density:2.07
Spec Gravity:1.5 @ 77F
Evaporation Rate & Reference:7.7 (ETHER=1)
Solubility in Water:PARTIAL
Appearance and Odor:RED-BLACK PASTE; ALCOHOLIC ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE FOLLOWING EPA AND LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:RISOGRAPH RA MASTER, S-568
CAGE:0LJK9
CAGE:0LJK9
============= Composition/Information on Ingredients =============
Ingred Name:POLYETHYLENE TEREPHTHALATE FILM. MFR'S CAS NO:25088-59-9.
MP:>392F,>200C.
CAS:25038-86-9
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:HEMP (STENCIL PAPER)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ADHESIVE; (ACRYL RESIN (ADHESIVES)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICONE (ANTI-STICKING AGENT)
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT) >SEVERAL G/KG.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:ORAL TOXICITY ON RATS: NO
INFORMATION IS AVAILABLE, BELIEVED TO BE GREATER THAN SEVERAL G/KG.
SKIN IRRITATION: NO INFORMATION IS AVAILABLE, BUT PROLONGED OR
FREQUENT CONTACT MAY CAUSE DERMATITIS .
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:UNKNOWN.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . EYES:IMMEDIATELY FLUSH
W/POTABLE WATER FOR A MINIMUM OF 15 MINUTES, SEEK ASSISTANCE FROM
MD. SKIN:WASH W/SOAP & WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . MASTER WILL BE FLAMMABLE AS PAPER.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:TO ASSURE THAT PRODUCTS WILL MAINTAIN
THEIR QUALITY THROUGHOUT STORAGE LIFE, DO NOT EXPOSE TO SUN, NOR
KEEP THEM IN A PLACE WHERE TEMPERATURES(SUPDAT)
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NOT NECESSARY.
Ventilation:LOCAL EXHAUST/MECHANICAL (GENERAL): NOT NORMALLY REQUIRED.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . NOT NORMALLY REQUIRED.
Work Hygienic Practices:NONE.
Supplemental Safety and Health
OTHER PREC:&/OR HUMIDITY ARE EXCEPTIONALLY HIGH.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:SEE ING 1
Solubility in Water:NONE
Appearance and Odor:WEB SHAPED, COLORED SLIGHT YELLOW; NEARLY ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CO ON INCOMPLETE COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . DISPOSE I/A/W STATE OR LOCAL LAW. SMALL QUANTITIES:
CONTROLLED BURNING. LARGE QUANTITIES: CONTACT LOCAL INDUSTRIAL
WASTE DISPOSAL COMP ANY FOR DISPOSAL.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:8655 TOLUIDINE BLUE,1% IN 20% ALCOHOL/1% GLACIAL ACETIC ACID
CAGE:RICCA
CAGE:RICCA
============= Composition/Information on Ingredients =============
Ingred Name:TOLUIDINE BLUE; C.I. 925; C.I. 52040; GABILIN; TOLONIUM
CHLORIDE
CAS:92-31-9
RTECS #:SP5670000
Fraction by Wt: 1%
Ingred Name:ETHANOL (ETHYL ALCOHOL), TECSOL, ALCOHOL
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 19.05%
Other REC Limits:1900 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ingred Name:METHANOL (METHYL ALCOHOL), COLUMBIAN SPIRITS
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 0.95%
Other REC Limits:200 PPM
OSHA PEL:260 MG/CUM
ACGIH TLV:262 MG/CUM (SKIN)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETIC ACID (GLACIAL)
CAS:64-19-7
RTECS #:AF1225000
Fraction by Wt: 1%
OSHA PEL:25 MG/CUM
ACGIH TLV:25 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 78%
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE SUPPLEMENTAL INFORMATION
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:LIMITED HAZARD DUE TO LOW
CONCENTRATION OF HAZARDOUS INGREDIENTS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:DROWSINESS, LOSS OF APPETITE, INABILITY TO
CONCENTRATE, HEADACHE, DIZZINESS, NAUSEA & CONJUNCTIVITIS.
Medical Cond Aggravated by Exposure:EYE PROBLEMS, SKIN DISORDERS,
IMPAIRED KIDNEY FUNCTION, CHRONIC RESPIRATORY DISEASE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER. SKIN: FLUSH IMMEDIATELY
W/WATER. REMOVE ANY CONTAMINATED CLOTHING. INHALATION: REMOVE TO
FRESH AIR. GIVE ARTIFICIAL RESPIRATION IF NECESSARY. INGESTION:
DILUTE IMMEDIATE LY W/WATER OR MILK. INDUCE VOMITING. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. ABSORB ON PAPER. EVAPORATE IN
HOOD. BURN IN PAPER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PHYSICAL DAMAGE.
============= Exposure Controls/Personal Protection =============
Ventilation:NORMAL ROOM IS ADEQUATE
Other Protective Equipment:LAB COAT OR LAB APRON
Work Hygienic Practices:WASH HANDS AFTER HANDLING THIS OR ANY OTHER
CHEMICAL BEFORE EATING, DRINKING OR SMOKING.
Supplemental Safety and Health
ORAL LD50 (RAT): ETHANOL: 7060 MG/KG, METHANOL: 5628 MG/KG, ACETIC
ACID: 3310 MG/KG.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text: 100C
Melt/Freeze Pt:M.P/F.P Text: 0C
Spec Gravity: 1
Solubility in Water:COMPLETE
Appearance and Odor:DARK BLUE LIQUID W/ODOR OF ALCOHOL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:MIX W/FLAMMABLE SOLVENT. ATOMIZE INTO AN
INCINERATOR W/AFTERBURNER & SCRUBBER. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:NR. 860 MOLDABLE POLYMER GASKETING
CAGE:71431
CAGE:71431
============= Composition/Information on Ingredients =============
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
OSHA PEL:350 PPM/450 STEL
ACGIH TLV:350 PPM/450STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:NAPHTHA (PETROLEUM SPIRITS OR BENZIN)
CAS:8030-30-6
RTECS #:SE7555000
OSHA PEL:100 PPM
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 1-5%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9192
Ingred Name:ISOBUTANE,15-20% (INGREDS 1-4,PACKAGED IN AEROSOL CAN,FORM
THE CATALYST PART OF THIS KIT)
CAS:75-28-5
RTECS #:TZ4300000
ACGIH TLV:1000 PPM (MFR)
Ingred Name:PUTTY (ACCD TO MFR,IS NOT CLASSIFIED AS A "HAZARDOUS MATL"
IN NORM USE AS- SEE SUPP DATA
===================== Hazards Identification =====================
Effects of Overexposure:INHAL OF VAPOR CONC > TLV MAY CAUSE
DIZZINESS,HEADACHE. PRLNG/RPTD SKIN CONT MAY (SEE OTHR PRECAUTN)
======================= First Aid Measures =======================
First Aid:INHAL: IF OVERCOME BY VAPS,REMOVE TO FRESH AIR. IF BREATHING
STOPS,GIVE ARTIFICIAL RESP. CALL PHYSICIAN. SKIN: WASH W/SOAP &
H*2O. EYES: FLUSH W/H*2O FOR AT LEAST 15 MIN. CONSULT PHYSICIAN.
INGEST: DO NT INDUCE VOMITING. CALL PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:60C,140F (CC)
Lower Limits:0.9%
Extinguishing Media:FOAM,DRY CHEMICAL,CO*2,OR H*2O FOG
Fire Fighting Procedures:COOL EXPOS CNTNRS W/H*2O. WEAR SCBA,FULL
PROTECTIV CLOTHING.
Unusual Fire/Explosion Hazard:THERMAL DECOMP CAN FORM HCL,PHOSGENE &
OTHR TOX FUMES. PRESSURIZED CNTNRS WHEN HEATED (SEE OTHR PREC
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. PROVIDE VENTILATION. CONTAIN
SPILL TO SMALL AREA. FLUSH AWAY FROM IGNITION SOURCES W/H*2O. PICK
UP W/ABSORBENT MATERIAL & TRANSFER TO A SUITABLE CONTAINER FOR
DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:DONT STORE IN DIR SUN/ABV 120F. NO
SMOKING IN AREA OF USE. DONT USE NEAR ARC WELDING,OPEN FLAME,HOT
SURF. HEAT &/OR UV RADIATION MAY FORM HCL,PHOSGENE
Other Precautions:BOILING PT,% VOLATILE & FLASH PT: GIVEN FOR AEROSOL.
UNUSUAL FIRE & EXPLO HAZ: ARE A POTENTIAL EXPLOSIVE HAZ. EFFECTS OF
OVEREXP: CAUSE SKIN IRRIT,MAY DEFAT SKIN. PRLNG EXPOSURE MAY IRRIT
EYES
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY NEEDED (AVOID INHALATION OF VAPORS
FROM CURING AGENT)
Ventilation:ROOM VENTILATION IS USUALLY ADEQUATE
Other Protective Equipment:NONE
Supplemental Safety and Health
IN U.S. DEPT OF LABOR REGULATIONS 29 CFR 1910.1200,1915,1916,1917.
THIS PROD,IN CARTRIDGE FORM,IS PART 2 OF THIS 2-PT KIT)
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:71C,160F
Vapor Density:>1
Evaporation Rate & Reference:<1 (ETHER)
Percent Volatiles by Volume:86
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS LIKE LIQUID CHLORINE & CONCENTRATED OXYGEN
Stability Condition to Avoid:OPEN FLAMES & RED HOT SURFACES
Hazardous Decomposition Products:HYDROGEN CHLORIDE,PHOSGENE & OTHER
TOXIC FUMES
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE ABSORBED MATERIAL. DO NOT INCINERATE
SEALED CONTAINERS. LANDFILL SEALED CONTAINERS IN AN APPROVED AREA.
WASTE DISPOSAL MUST BE IAW FEDERAL,STATE & LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:7322H EXPRESS VINYL POLYSILOXANE IMPRESSION MATERIAL
CAGE:76381
CAGE:76381
============= Composition/Information on Ingredients =============
Ingred Name:SILICON DIOXIDE (AMORPHOUS)
CAS:67762-90-7
Fraction by Wt: 2-5% %
Other REC Limits:NONE RECOMMENDED
Ingred Name:VINYL POLYSILOXANE CATALYST
CAS:68083-19-2
Fraction by Wt: 37-43% %
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 45-55% %
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3 RDUST; Z-3
ACGIH TLV:0.1 MG/M3 RDUST;9394
Ingred Name:COBALT PIGMENT CATALYST
CAS:1345-16-0
Fraction by Wt: < 1% %
Other REC Limits:NONE RECOMMENDED
Ingred Name:VINYL POLYSILOXANE BASE
CAS:68083-19-2
Fraction by Wt: 30-35% %
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICA, CRYSTALLINE - QUARTZ BASE
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 45-55% %
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3 RDUST; Z-3
ACGIH TLV:0.1 MG/M3 RDUST;9394
Ingred Name:SILOXANE COPOLYMERBASE
CAS:68037-59-2
Fraction by Wt: 5-10% %
Other REC Limits:NONE RECOMMENDED
Ingred Name:COBALT PIGMENT BASE
CAS:1345-16-0
Fraction by Wt: < 3%
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMORPHOUS SILICA BASE
CAS:67762-40-7
Fraction by Wt: 2-5% %
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:MILD EYE IRRITATION. NOT EXPECTED TO
BE IRRITATING TO THE SKIN. CONSIDERED PRACTICALLY NON-TOXIC ORALLY.
SWALLOWING A RELATIVELY LARGE AMOUNT OF THIS MATERIAL IS UNLIKELY
TO PRODUCE SERIOUS ILLNESS OR DEATH. NOTE: CRYSTALLINE SILICON
DIOXIDE HAS BEEN SHOWN TO PRODUCE SILICOSIS IN HUMANS. HOWEVER,
UNLIKELY FOR PRODUCT.
Explanation of Carcinogenicity:SILICA QUARTZ IS A POTENTIAL CANCER
HAZARD, NTP ANTICIPATED HUMAN CARCINOGEN, IARC 2A-PROBABLE HUMAN
CARCINOGEN.
Effects of Overexposure:EYE REDNESS, SWELLING, PAIN AND TEARING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE CONTACT: IMMEDIATELY FLUSH WITH LARGE AMOUNTS OF WATER
FOR AT LEAST 15 MINUTES. GET IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:WATER, CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL. COVER WITH ABSORBENT MATERIAL.
COLLECT SPILLED MATERIAL. PLACE IN AN APPROVED METAL CONTAINER AND
SEAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
DO NOT INGEST.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NOT GIVEN
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:NOT GIVEN
Spec Gravity:1.4
Viscosity:130000CPS
Evaporation Rate & Reference:NIL
Solubility in Water:INSOLUBLE
Appearance and Odor:VISCOUS LIQUIDS, PURPLE COLOR, NO ODOR
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:358-364 ROTARY
Preparer's Name:DICK KARBO
CAGE:KMADD
CAGE:KMADD
============= Composition/Information on Ingredients =============
Ingred Name:COPPER COMPOUND
Fraction by Wt: 5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED CONTACT W/SKIN/EYES CAN
CAUSE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMEDIATELY W/WATER. SKIN: WASH AFFECTED AREA
W/SOAP & WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>200F
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: WIPE UP & STORE WIPERS IN UNDERWRITERS
APPROVED CONTAINERS. LARGE: SCOOP MATERIAL INTO SEALABLE
CONTAINERS. WIPE UP REMAINDER & STORE WIPERS IN UNDERWRITERS
APPROVED CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS.
Other Precautions:AVOID CONTACT W/SKIN, EYES & CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS REQUIRED
Ventilation:LOCAL EXHAUST
Work Hygienic Practices:WASH AFTER USE. REMOVE/LAUNDER CONTAMINATED
CLOTHING BEFORE REUSE. DON'T CONSUME FOOD/BEVERAGE WHERE PRODUCT IS
USED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:470-610F
Evaporation Rate & Reference:SLOWER THAN WATER
Solubility in Water:INSOLUBLE
Appearance and Odor:OILY
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:RB68B ELECTROSTATIC TONER REPLENISHER, 1713
Preparer's Name:CRAIG SUNDQUIST
CAGE:IO122
CAGE:IO122
CAGE:14668
============= Composition/Information on Ingredients =============
Ingred Name:ING 12:AGENCY FOR ASSISTANCE. POSS DISP METHODS INCL
INCINERATION OR RECYCLING FOR USE AS PARTS CLEANING SOLVS. (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:RECYCLED MATERIALS SHOULD NOT BE USED WITH CALCOMP
PLOTTERS.
RTECS #:9999999ZZ
Ingred Name:VENT:THE AMERICAN SOCIETY OF HEATING, AIR CONDITIONING &
REFRIGERATING ENGINEERS (ASHRAE)1980 STANDARDS IF ADEQ (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:UNDER NORMAL CNDTNS OF USE. UNDER SOME CNDTNS OF USE
OR COMBINATIONS OF EQUIP, OFFICE VENT MAY NOT BE (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:ADEQ. USERS SHOULD CONSULT A QUALIFIED VENT ENGINEER
AND/OR INDUSTRIAL HYGIENIST IF A CONCERN REGARDING (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:EXPOSURE ARISES.
RTECS #:9999999ZZ
Ingred Name:ACRYLIC POLYMER/RESIN
CAS:28430-58-2
Fraction by Wt: <12%
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: <3%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:HYDROCARBON PARAFFINIC SOLVENT; (ISOPARAFFINIC PETROLEUM
SOLVENT)
CAS:64742-48-9
Fraction by Wt: >84%
Other REC Limits:300 PPM (MFR)
Ingred Name:DYE
Fraction by Wt: <1%
Ingred Name:SUPP DATA:WITH FEMALE RATS & MALE & FEMALE MICE & IN
LIMITED STUDIES WITH OTHER ANIMAL SPECIES. ADDITIONALLY, (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:IN A NUMBER OF HUMAN STUDIES, THERE WAS NO CLINICAL
EVIDENCE OF SUCH EFTS AT NORMAL OCCUPATIONAL LEVELS. (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:IT IS THEREFORE HIGHLY UNLIKELY THAT KIDNEY EFTS
OBSERVED IN MALE RATS HAVE SIGNIFICANT IMPLICATIONS FOR (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:EXPOSED AT OR BELOW THE RECOMMENDED VAPOR LIMITS IN
THE WORKPLACE.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:DO NOT INDUCE VOMITING. CALL MD IMMEDIATELY.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:PRECS FOR VOLATILE, COMBUSTIBLE VAPS FROM
ABSORBED MATL. THERE IS NO REPORTABLE QUANTITY UNDER CERCLA(ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:REPORTING REQUIREMENTS.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH:SOLVS & PETROLEUM BASED OILS. CONTACT A
LICENSED HAZ WASTE DISP COMPANY OR ENVIRON CONTROL (ING 13)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL RAT) 5 G/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN:CAN CAUSE DRYING OR IRRITATION.
EYE:MAY CAUSE IRRITATION. INHAL:VAPORS MAY CAUSE HDCH & DIZZ.
INGEST:IF ASPIR INTO LUNGS DURING INGEST OR VOMIT, MAY CAUSE MILD
TO SEVERE PULM INJURY & POSS DEATH . PRODUCT HAS BEEN INTENSIVELY
TESTED. WHEN USED AS INTENDED, IT DOES NOT REPRESENT (EFTS OF
OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:ANY KNOWN HLTH OR SAFETY HAZ. HIGH VAP
CONC (>1000 PPM) ARE IRRITATING TO EYES & RESP TRACT, MAY CAUSE
HDCH & DIZZ, ARE ANESTHETIC, & MAY HAVE OTHER CNS EFTS. DEATH IS
POSS IF EXPOSED TO VERY HIGH CONC FOR PRLNGD PERIODS. PERSONS
SENSITIVE TO HYDROCARBON EXPOS MAY EXPERIENCE DISCOMFORT WHEN
EXPOSED (SUPDAT)
Medical Cond Aggravated by Exposure:SKIN CONTACT MAY AGGRAVATE AN
EXISTING DERMATITIS.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/CLEAR WATER FOR AT LEAST 15 MINS OR UNTIL IRRIT
SUBSIDES. IF IRRIT PERSISTS, CALL MD. SKIN:REMOVE CONTAM CLTHG.
WASH SKIN THORO W/SOAP & WATER. DO NOT REUSE CONTAM CLTHG UNTIL
SOLVS HAVE B EEN REMOVED. INHAL:MOVE TO FRESH AIR. CALL MD IMMED.
IF BRTHG IRREGULAR OR STOPPED, START RESUSCITATION IF TRAINED. GIVE
O*2 IF AVAIL. INGEST:DILUTE STOMACH CONTENTS W/SEV GLASSES OF
WATER. (ING 9)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>102F,>39C
Lower Limits:0.8%
Upper Limits:7%
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE OR WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . AVOID WATER, IT TENDS TO SPREAD HYDROCARBON
FIRES.
Unusual Fire/Explosion Hazard:KEEP PRODUCT AWAY FORM IGNITION SOURCES
SUCH AS HEAT, SPARKS, PILOT LIGHTS, STATIC ELECTRICITY, ELECTRICAL
APPLIANCES & OPEN FLAMES.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNIT SOURCES. RECOVER FREE PROD
BY ADDING SAND, EARTH OR OTHER SUITABLE ABSORBENT TO SPILLED LIQ.
KEEP NON-ESSENTIAL PERS AWAY. AVOID BRTHG VAPS. VENT CONFINED
SPACES. CLEAN-UP ABSORB M ATL/DISP OF PROPERLY. CONTINUE TO
OBSERVE(ING 10)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:"EMPTY" CONTAINERS RETAIN RESIDUE
(LIQUID AND/OR VAPOR) AND CAN BE DANGEROUS.
Other Precautions:DISPOSE OF PROPERLY. KEEP CONTAINERS CLOSED WHEN NOT
IN USE. DO NOT SMOKE WHEN USING PRODUCT. MINIMIZE BREATHING VAPOR
OR MIST. USE WITH ADEQUATE VENTILATION. AVOID PROLONGED OR REPEATED
SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NEEDED WHEN USED AS INTENDED WITH CALCOMP
PRODUCTS. IN CONCENTRATIONS EXCEEDING THE RECOMMENDED SAFE EXPOSURE
LIMIT, SUCH AS DURING A MAJOR SPILL, USE A NIOSH/MSHA APPROVED
CHEMICAL CARTRIDGE RESP IRATOR EFFECTIVE FOR ORGANIC VAPORS.
Ventilation:NO SPECIAL VENTILATION IS NEEDED WHEN USED AS INTENDED
W/CALCOMP PRODS. NORMAL OFFICE VENT CONFORMING TO (ING 15)
Other Protective Equipment:CHEMICAL RESISTANT APRON WHEN CLEANING
MACHINES AS REPLENISHERS MAY STAIN CLOTHING.
Work Hygienic Practices:WHENEVER HANDLING CHEMICALS, ALWAYS USE GOOD
PERSONAL HYGIENE PRACTICES, SUCH AS WASHING YOUR HANDS AFTER DONE.
Supplemental Safety and Health
PH:ESSENTIALLY NEUTRAL. EFTS OF OVEREXP:TO CONC BELOW ESTABLISHED SAFE
EXPOS LIMIT. LAB ANIMAL STUDIES HAVE SHOWN THAT PRLNGD/RPTD INHAL
EXPOS TO LIGHT HYDROCARBON VAPS IN SAME NAPHTHA BOILING RANGE A S
PROD CAN PRODUCE ADVERSE KIDNEY EFTS IN MALE RATS. HOWEVER, THESE
EFTS WERE NOT OBSERVED IN SIMILAR STUDIES (ING 5)
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:>320F,>160C
Vapor Pres:1 @ 20C
Vapor Density:5
Spec Gravity:0.76 (H*2O=1)
pH:SUPDAT
Evaporation Rate & Reference:0.25-0.45(BU AC=1)
Solubility in Water:IMMISCIBLE
Appearance and Odor:BLACK LIQUID WITH SLIGHT PETROLEUM HYDORCARBON ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS LIKE LIQUID CHLORINE, CONCENTRATED OXYGEN, & SODIUM
HYPOCHLORITE OR CALCIUM HYPOCHLORITE.
Stability Condition to Avoid:SOURCES OF IGNITION.
Hazardous Decomposition Products:SMIKE, CARBON MONOXIDE, ALDEHYDES, &
OTHER DECOMPOSITION PRODUCTS WHICH MAY OCCUR IN THE EVENT OF
INCOMPLETE COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:RCRA HAZ WASTE NO.-D001. WASTE TONERS &
REPLENISHERS ARE HAZ WASTES AS DEFINED BY 40 CFR CHAPTER 1
(FLAMMABILITY). ASSURE CONFORMITY W/ALL APPLIC FED/STATE/LOC REGS.
WASTE TONERS & REPLENISHERS ARE CO MPATIBLE FOR DISP W/MOST
NON-HALOGENATED(ING 12)
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CAUSTIC POTASH
CAGE:OO277
CAGE:OO277
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
OSHA PEL:C, 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:CORROSIVE TO SKIN AND MUCOUS MEMBRANES,CAUSES
SEVERE AND RAPID BURNS.
======================= First Aid Measures =======================
First Aid:REMOVE FROM SKIN AS SOON AS POSSIBLE.WASH AFFECTED AREA
W/WATER FOR AT LEAST 15 MINUTES.SEEK MEDICAL ATTENTION AT ONCE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Other Protective Equipment:ACID TYPE SUIT
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:B1
Boiling Pt:B.P. Text:292
Spec Gravity:1.45
Solubility in Water:COMPLETE
Appearance and Odor:VISCOUS,WATER-WHITE LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS
==================== Disposal Considerations ====================
Waste Disposal Methods:DILUTE AND WASH AWAY WITH LARGE AMOUNTS OF
WATER.NEUTRALIZE(AFTER DILUTING)WITH ACID,IF REQUIRED BY LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:BLEACH
Preparer's Name:HARRY AUSTIN III
CAGE:6Z316
CAGE:6Z316
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYPOCHLORITE (NAOCL) (SARA III)
CAS:7681-52-9
RTECS #:NH3486300
Fraction by Wt: 5.25%
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:SODIUM HYDROXIDE (CAUSTIC SODA) (NAOH) (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 0.10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS 5800MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:MAY CAUSE SEVERE
IRRITATION.SKIN:MAY CAUSE SEVERE IRRITATION.INGEST:MAY CAUSE SEVERE
GI TRACT IRRITATION.INHAL: MAY CAUSE SEVERE RESPIRATORY IRRITATION.
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of Overexposure:INHAL:RASPY CONTINUOUS COUGHING,RUNNY NOSE.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING CUTS OR
ABRASIONS MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH WATER.EYES:FLUSH
WITH WATER FOR 15 MINUTES.INHAL:REMOVE TO FRESH AIR.GIVE OXYGEN OR
ARTIFICIAL RESPIRATION IF NEEDED.INGEST:DO NOT INDUCE VOMITING. GET
PROM PT QUALIFIED MEDICAL ATTENTION.DO NOT GIVE LIQUIDS IF DROWSY,
OTHERWISE GIVE WATER OR MILK;AVOID ALCOHOL.DO NOT USE BAKING SODA
OR ACIDIC ANTIDOTES.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>200F,>93C
Extinguishing Media:WATER, CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL FOAM.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.COOL FIRE EXPOSED CONTAINERS WITH WATER
FOG.
Unusual Fire/Explosion Hazard:CONTAINERS MAY BURST AT ELEVATED
TEMPERATURES.
================== Accidental Release Measures ==================
Spill Release Procedures:NEUTRALIZE WITH SODIUM SULFITE OR FERROUS
SALTS;BE CAUTIOUS OF CHLORINE FUMES BEING GIVEN OFF DURING
NEUTRALIZATION; SOAK UP WITH A NON-COMBUSTIBLE INERT
ABSORBANT;PLACE IN AN APPROPRIATE CONTAINER FO R DISPOSAL;MOP SPILL
AREA;AVOID DISCHARGE TO SEWER
Neutralizing Agent:SODIUM SULFITE OR FERROUS SALT.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID HEAT AND DIRECT SUNLIGHT.KEEP
CONTAINERS UPRIGHT AND CLOSED.KEEP AWAY FROM FOOD.SEPERATE FROM
ACIDS, AMMONIA,SOAP BASED PRODUCTS OR ORGANIC MATL
Other Precautions:FOLLOW LABEL DIRECTIONS.AVOID BREATHING VAPORS.AVOID
SKIN AND EYE CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE ENVIRONMENTAL CONTROLS ARE LACKING OR IN
ENCLOSED SPACES USE EITHER A SELF-CONTAINED BREATHING APPARATUS OR
A NOISH/ MSHA APPROVED RESPIRATOR FOR CAUSTIC VAPORS,DEPENDING ON
THE AIRBORN CONCENTR ATION.
Ventilation:USE GENERAL DILUTION VENTILATION.
Other Protective Equipment:SMOCKS FOR PROTECTION OF CLOTHING;PRODUCT
WILL FADE COLORS.
Work Hygienic Practices:USE REASONABLE CARE IN HANDLING THIS
PRODUCT.WASH HANDS AFTER USE AND BEFORE EATING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:B1
Boiling Pt:=100.C, 212.F
Melt/Freeze Pt:=0.C, 32.F
Vapor Pres:23
Spec Gravity:1.080
pH:12.5
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR YELLOW LIQUID; TYPICAL CHLORINE ODOR
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, AMMONIAS, OILS, GREASES, SOAPS, HEAVY METALS, AND ETHER.
Stability Condition to Avoid:HEAT OR DIRECT SUNLIGHT.
Hazardous Decomposition Products:CHLORINE GAS OR CHLORAMINES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:MIL-C-22750E EPOXY PART A
Kit Part:Y
Preparer's Name:DAVID SCHMETTERER
CAGE:DO165
CAGE:DO165
CAGE:5V430
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BISPHENOL A-EPICHLOROHYDRIN
CAS:25085-99-8
Fraction by Wt: 45%
Other REC Limits:NONE SPECIFIED
Ingred Name:ALIPHATIC GLYCIDYL ETHER (THIS MATERIAL CONTAINS <0.005% BY
WEIGHT EPICHLOROHYDRIN CAS #106-89-8 WHICH HAS A OSHA TWA*
CAS:68609-97-2
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
Ingred Name:*OF 2 PPM. THE POTENTIAL CONTRIBUTION OF EPICHLOROHYDRIN TO
OVERALL EXPOSURE IS POSSIBLE VIA SKIN ABSORPTION).
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
Ingred Name:METHYL ETHYL KETONE (VAPOR PRESSURE 71.2 MM HG)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SILICA, CRYSTALLINE
CAS:14464-46-1
RTECS #:VV7325000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.05 MG/M3 RDUST9293
Ingred Name:VOC: 207 GPL.
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE TOXICITY RESULTING IN HEADACHE/
DIZZINESS/NAUSEA/UNCONSCIOUSNESS. SEVERE EYE IRRITATION POSSIBLY
RESULTING IN PERMANENT DAMAGE. IRRITATED MUCOUS MEMBRANES. VOMITING
DUE TO INGESTION. DEFATTING A ND DRYING OF SKIN. SENSITIZATION
AFTER REPEATED CONTACT. IT IS VERY UNLIKELY THAT NORMAL WORK
OPERATIONS WITH THIS RESIN
Explanation of Carcinogenicity:LIMITED EVIDENCE OF CARCINOGENICITY OF
CRYSTALINE SILICA TO HUMANS.
Medical Cond Aggravated by Exposure:COULD PRODUCE ATMOSPHERIC
CONCENTRATIONS APPROACHING OSHA LIMIT. HOWEVER YOU SHOULD BE AWARE
THAT IR HAS BEEN REPORTED TO CAUSE CANCER IN LABORATORY ANIMALS.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/PLENTY/CLEAN/LUKEWARM/LOW PRESSURE WATER 15 MIN,
LIFT LIDS OPEN. GET MED AID. INHALE: MOVE VICTIM TO FRESH
AIR/PROVIDE OXYGEN/ARTIFICIAL RESPIRATION IF NEEDED. GET MED AID.
KEEP WARM/COMF ORTABLE. NEVER GIVE AN UNCONSCIOUS PERSON LIQUIDS.
INGEST: CALL DR IMMED. ONLY INDUCE VOMITING ON INSTRUCT OF DR. IF
VOMITING OCCURS, KEEP HEAD BELOW HIPS-PREVENT ASPIRATION INTO
LUNGS. SKIN: FLUSH
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:22.0F,-5.6C
Lower Limits:1.2
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WATER TO KEEP EXPOSED CONTAINERS COOL/
FLAMMABLE STRUCTURES WET. DO NOT ENTER FIRE AREA W/O PROPER
PROTECTION BECAUSE HAZARDOUS DECOMP PRODUCTS MAY BE PRESENT.
Unusual Fire/Explosion Hazard:WATER PRESSURE MAY SPREAD A FLAMMABLE
LIQUID FIRE. SEALED CONTAINERS MAY EXPLODE IF OVERHEATED.
================== Accidental Release Measures ==================
Spill Release Procedures:WARNING-FLAMMABLE. ELIMINATE ALL IGNITION
SOURCES. HANDLING EQUIPMENT MUST BE GROUNDED TO PREVENT SPARKING.
SOAK UP WITH AN ABSORBENT AND PLACE IN NON-LEAKING CONTAINERS. SEAL
TIGHTLY FOR PROPER DISPO SAL.
======================Handling and Storage ======================
Handling and Storage Precautions:TREAT AS HAZARDOUS-FLAMMABLE MATERIAL.
HOT ORGANIC CHEMICAL VAPORS/MISTS ARE SUSCEPTIBLE TO SPONTANEOUS
COMBUSTION WHEN MIXED W/AIR.
Other Precautions:W/WATER WHILE REMOVING CONTAMINATED CLOTHING/SHOES.
WASH W/SOAP/WATER. DO NOT REUSE CONTAMINATED CLOTHING/SHOES. IF
IRRITATION PERSISTS. GET MED AID.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MUST PROVIDE ADEQUATE VENTILATION TO MAINTAIN
VAPOR CONCENTRATIONS BELOW THE ESTABLISHED TLV LIMIT AS GIVEN BY
OSHA. IN MORE CONFINED AREAS A NIOSH/MSHA APPROVED RESPIRATOR
EQUIPPED WITH ORGANIC VAPOR CARTRIDGE SHOULD BE WORN.
Ventilation:MUST PROVIDE ADEQUATE VENTILATION.
Other Protective Equipment:HAVE EYE BATH AND SAFETY SHOWER AVAILABLE.
Supplemental Safety and Health
KEY1;F5.
================== Physical/Chemical Properties ==================
HCC:F5
Boiling Pt:B.P. Text:174FTO232F
Vapor Density:>AIR
Spec Gravity:1.13
Viscosity:7200 CENT
Evaporation Rate & Reference:3.47 (X N-BUTYL ACETATE)
Solubility in Water:SLIGHT
Appearance and Odor:WHITE/SOLVENT ODOR.
Percent Volatiles by Volume:25
Corrosion Rate:NOT CORR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS/STRONG ALKALIES.
Stability Condition to Avoid:AVOID HEAT/SPARKS/OPEN FLAMES/OXIDIZING
AGENTS/STRONG ALKALIES.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION FOR PRODUCTS
LIKE THIS MAY GENERATE HIGHLY POISONOUS CARBON MONOXIDE AND OTHER
TOXIC GASES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH CURRENT
LOCAL, STATE AND FEDERAL REGULATIONS. CONTACT AN APPROVED DISPOSAL
FACILITY.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:WALLBOARD JOINT COMPOUND, 2017
Preparer's Name:TERI JAMESON
CAGE:CUSTO
CAGE:CUSTO
============= Composition/Information on Ingredients =============
Ingred Name:CALCIUM CARBONATE; (LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 70%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:NONE CURRENTLY KNOWN.
INHALATION:NONE CURRENTLY KNOWN. SKIN AND EYE CONTACT:MAY CAUSE
TRANSIENT REDDENING OF SKIN. MAY CAUSE SLIGHT EYE IRRITATION.
INGESTION:NONE CURRENTLY KNOWN. MAY CAUSE NAUS EA. CHRONIC:NONE
CURRENTLY KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGESTION:CALL MD IMMEDIATELY . INHALATION:REMOVE TO FRESH
AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP) . EYES:FLUSH WITH WATER
FOR AT LEAST 15 MINUTES. SKIN:WASH WITH SOAP AND WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE . NONE KNOWN.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . NONE.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:MAJOR SPILLS SHOULD BE COLLECTED FOR DISPOSAL.
MINOR SPILLS MAY BE FLUSHED TO SEWER IF LOCAL REGULATIONS PERMIT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NONE REQUIRED.
Ventilation:GENERAL ROOM VENTILATION IS EXPECTED TO BE SATISFACTORY.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER . ADEQUATE CLOTHING SHOULD BE WORN TO PREVENT SKIN CONTACT.
Work Hygienic Practices:GOOD HOUSEKEEPING PRACTICES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Density:HVR/AIR
Spec Gravity:1.8 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INFINITELY DILUTABLE
Appearance and Odor:WHITE, TROWELABLE PASTE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:WHEN WATER EVAPORATES, POLYMER CAN
BURN AND PRODUCE CARBON DIOXIDE AND CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . BURY IN SUITABLE LANDFILL WHERE PERMITTED UNDER
APPROPRIATE GOVERNMENT REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:WHITE (M-3) MARKER BASE, 8710
Preparer's Name:VILMA HOLMGREN
CAGE:ITWFL
CAGE:98148
CAGE:ITWFL
============= Composition/Information on Ingredients =============
Ingred Name:XYLENE; (MIXED XYLENES, ETHYL BENZENE) (SARA 313) (CERCLA)
VP:14 @ 100F, LD50(ORAL,RAT):4.3 G/KG
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 51-70%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER;
(1-METHOXY-2-PROPANOL ACETATE) VP:3.7 @ 68F
CAS:108-65-6
RTECS #:AI8925000
Fraction by Wt: 11-30%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:2-PROPANOL, 1-METHOXY-; (1-METHOXY-2-PROPANOL) VP:12.5 @
25C, LD50(ORAL,RAT):6.6 ML/KG
CAS:107-98-2
RTECS #:UB7700000
Fraction by Wt: 1-5%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION:HIGH CONCENTRATIONS
OF VAPORS MAY PRODUCE IRRITATION OF THE RESPIRATORY TRACT,
HEADACHE, DIZZINESS AND NAUSEA. SKIN AND EYE CONTACT:MODERATE
IRRITATION. SKIN ABSORPTION:MODERATE IRRIT ANT. INGESTION:SIMILAR
TO INHALATION. SYMPTOMS:NAUSEA AND VOMITING. DO NOT INDUCE
VOMITING. IF VOMIT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:OCCURS KEEP HEAD BELOW HIPS TO
PREVENT ASPIRATION OF LIQUID INTO LUNGS. CALL A PHYSICIAN
IMMEDIATELY. CHRONIC:PROLONGED REPEATED OVEREXPOSURE TO THIS
PRODUCT MAY LEAD TO SKIN SENSITIZATION O R DERMATITIS.
Medical Cond Aggravated by Exposure:SKIN DISORDERS, RESPIRATORY
DISORDERS.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WELL WITH WATER FOR AT LEAST 15 MINUTES. CONTACT A
PHYSICIAN IF IRRITATION PERSISTS. SKIN:WASH WITH SOAP AND WATER.
INHALATION:REMOVE PATIENT TO FRESH AIR. IF BREATHING IS DIFFICULT,
ADMINI STER OXYGEN. INGESTION:DO NOT INDUCE VOMITING. CONTACT A
PHYSICIAN. IF VOMITING OCCURS, KEEP HEAD BELOW HIPS TO PREVENT
ASPIRATION OF LIQUID INTO LUNGS.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:81.0F,27.2C
Lower Limits:1.3%
Upper Limits:13.1%
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND MAY
TRAVEL ALONG GROUND, OR BE MOVED BY VENTILATION AND BE IGNITED BY
IGNITION SOURCE.
================== Accidental Release Measures ==================
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION. "EMPTY"
CONTAINERS RETAIN RESIDUE (LIQUID AND/OR VAPOR) AND CAN BE
DANGEROUS.
Other Precautions:DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL,
GRIND/EXPOSE SUCH CNTNRS TO HEAT, SPKS, FLAMES, STATIC ELEC/OTHER
SOURCES OF IGNIT. WARNING:MANY HOT ORG CHEM VAPS/MISTS ARE
SUSCEPTIBLE TO SUDDEN S PONT COMBUST WHEN MIXED W/AIR. IGNIT MAY
OCCUR @ TEMPS BELOW THOSE PUBLISHED IN LITERATURE AS "AUTOI GNIT"/
(SUP DAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED FOR NORMAL USE WITH ADEQUATE
VENTILATION. IF POORLY VENTILATED AREAS, USE NIOSH/MSHA APPROVED
ORGANIC VAPOR RESPIRATOR.
Ventilation:LOCAL EXHAUST IS RECOMMENDED FOR CONFINED AREAS. GENERAL
MECHANICAL VENTILATION IS ADEQUATE FOR NORMAL USE.
CHLORIDE-COATED TO MINIMIZE SKIN CONT
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER . OTHER PROTECTIVE GEAR AS REQUIRED TO MINIMIZE SKIN
CONTACT.
Work Hygienic Practices:FOLLOW CURRENT H.M.I.S. REGULATIONS.
Supplemental Safety and Health
OTHER PRECS:"IGNIT" TEMPS. IGNIT TEMPS DECR W/INCREASING VAP VOL & VAP
VOL & VAP/AIR CONT TIME, & ARE INFLUENCED BY PRESS CHANGES. IGNIT
OF ORG CHEM VAPS MAY OCCUR AT TYPICAL ELEVATED TEMP PROCESS CND
TNS, ESP IN PROCESSES OPERATING UNDER ELEVATED PRESS IF SUDDEN
ESCAPE OF VAPS/MISTS TO ATM OCCURS. ANY (OTHER INFO)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>248F,>120C
Vapor Pres:SEE INGS
Vapor Density:>1
Spec Gravity:0.92 (H*2O=1)
VOC Grams/Liter:6.02
Evaporation Rate & Reference:>1 (BUAC=1)
Solubility in Water:APPRECIABLE
Appearance and Odor:WHITE OPAQUE LOW VISCOSITY LIQUID WITH SWEET
SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, AND OPEN FLAMES.
Hazardous Decomposition Products:OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:REMOVE TO A WASTE DISPOSAL FACILITY OPERATING IN
COMPLIANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS. APPLICABLE
CERCLA/RCRA HAZ WASTE CODES:D001 (IGNITABILITY); U031 (BUTYL
ALCOHOL). REPORTABLE QUAN TITY UNDER CERCLA, IN POUNDS:100.
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CADMIUM OXIDE,99.99 + %,20289-4
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:CADMIUM OXIDE (SARA 302/313) (CERCLA)
CAS:1306-19-0
RTECS #:EV1925000
Fraction by Wt: >99.99%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 MG (CD)/M3 DUST
ACGIH TLV:0.01 MG(CD)/M3; 9596
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS 72 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:TARGET ORGANS:KIDNEYS, LUNGS. ACUTE-
MAY BE FATAL IF INHALED, SWALLOWED OR ABSORBED THROUGH SKIN. CAUSES
EYES AND SKIN IRRITATION. HIGHLY TOXIC. INHALATION OF DUST MAY
CAUSE UPPER RESPIRATORY TRACT IR RITATION. EXPOSURE CAN CAUSE
NAUSEA, VOMITING, HEADACHE. CHRONIC- DAMAGE TO KIDNEYS AND LUNGS.
Explanation of Carcinogenicity:CONTAINS C[7440-43-9] WHICH IS
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:IRRITATION, COUGHING, HEADACHE, NAUSEA,
VOMITING
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS OR IMPAIRED KIDNEY OR RESPIRATORY FUNCTION
MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:MOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES/SKIN:IMMEDIATELY FLUSH WITH
WATER FOR 15 MINUTES. HOLD EYELIDS OPEN. ORAL:IF CONSCIOUS, WASH
OUT MOU TH WITH WATER. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NOT RELEVANT
Upper Limits:NOT RELEVANT
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. HAZARDOUS DECOMPOSITION
PRODUCTS MAY BE FORMED.
Unusual Fire/Explosion Hazard:POWDERED MATERIAL MAY FORM EXPLOSIVE
DUST-AIR MIXTURES.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS,
CREATING DUST. PLACE IN A BAG. HOLD FOR DISPOSAL. VENTILATE AREA
AND WASH SPILL SITE AFTER PICKUP I S COMPLETE.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE AWAY FROM
INCOMPATIBLES. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:HIGHLY TOXIC. DO NOT RAISE DUST. AVOID CONTACT WITH
EYES, SKIN OR CLOTHING. AVOID INHALATION OF DUST. WASH THOROUGHLY
AFTER HANDLING MATERIAL. KEEP OUT OF REACH OF CHILDREN. DO NOT
INGEST. USE ONLY IN A CHEMICAL FUME HOOD.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH-APPROVED DUST RESPIRATOR OR DUST
MASK. IN EMERGENCY WEAR NIOSH-APPROVED SELF-CONTAINED BREATHING
APPARATUS.
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP FUME OR
DUST LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER, PROTECTIVE
CLOTHING AND/OR UNIFORM
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH BEFORE EATING OR DRINKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:T4
NRC/State Lic Num:NOT RELEVANT
Spec Gravity:8.15
Viscosity:NOT RELEVANT
Evaporation Rate & Reference:NOT RELEVANT
Appearance and Odor:RED-BROWN POWDER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, ACIDS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT A LICENSED PROFESSIONAL WASTE DISPOSAL
SERVICE TO DISPOSE OF THIS MATERIAL. OBSERVE LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:775655 17, EN ALKYD, SEMI-GLOSSLO VOC CT GRAY(SUPDAT)
Preparer's Name:MARTIN MARIETTA
CAGE:PRATT
CAGE:PRATT
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:XYLENE (SARA III). VP:5 @ 20C. LEL:1%. UEL:7%.
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 10%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM;150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETIC ACID, BUTYL ESTER; (N-BUTYL ACETATE) (SARA III).
VP:10 @ 20C. LEL:1.7%. UEL:7.6%.
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 5%
OSHA PEL:150 PPM
ACGIH TLV:150 PPM;200 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 15%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:SILICA GEL; (SILICA, AMORPHOUS HYDRATED)
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 5%
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (TALC)
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 20%
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (SILICA, CRYSTALLINE)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <1%
OSHA PEL:10 MG/M3 RDUST
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:2-HEXANONE, 5-METHYL-; (METHYL ISOAMYL KETONE)
CAS:110-12-3
RTECS #:MP3850000
Fraction by Wt: 5%
OSHA PEL:50 PPM (MFR)
ACGIH TLV:50 PPM
Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE) (MEK) (SARA III). VP:70
@ 20C. LEL:2%. UEL:10%.
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 5%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM;300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VOLATILE ORGANIC COMPONENT: 2.97 LB/GAL, 356 G/L (LESS
WATER & NPRS); 5.1 LB/GAL, 612 G/L (SOLIDS).
RTECS #:9999999VO
Ingred Name:SUPDAT:PRLNG & RPTD OCCUP OVEREXP TO SOLVS W/PERM BRAIN &
NERV SYS DMG. INTENTIONAL MISUSE BY DELIB CONC & INHAL(ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:CONTENTS MAY BE HARMFUL/FATAL. DRY TITANIUM DIOXIDE
IN 24-MONTH INHAL STUDY W/RATS REVEALED SIGNIFICANT (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:INCR IN BENIGN & MALIGNANT LUNG TUMORS IN GRP EXPOS
TO 250 MG/M3 RESPIRABLE TIO2 DUST. NORMAL CLEARANCE (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:MECHS OF LUNGS MAY HAVE BEEN OVERWHELMED AT 250
MG/M3 EXPOS LEVEL & THIS MAY HAVE CONTRIBUTED TO TUMOR (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:FORM. THERE RSLTS MAY NOT BE DIRECTLY RELEVANT TO
WORKPLACE WHERE OCCUP EPXOS LIMS ARE OBSERVED. LAB (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:STUDIES INVOLVING RATS INDICATE SOME EVID THAT
METHYL ETHYL KETONE MAY BE EMBRYOTOX, FETOTOX & TERATOGENIC.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:NOTES TO MD:ANY TREATMENT THAT MIGHT BE REQD
FOR OVEREXP SOULD BE DIRECTED AT CONTROL OF SYMPS (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:& CLINICAL CONDITIONS.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:USE ONLY NON-SPARKING TOOLS. PLACE ABSORB DIKING
MATLS IN COVERED METAL CNTNRS FOR DISP. PVNT CONTAM (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:OF SEWERS, STREAMS & GROUNDWATER W/SPILLED MATL OR
USED ABSORBENT.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:RESTRICTED VENT AREAS NIOSH/MSHA APPRVD CHEM
CARTRIDGE RESP MAY BE REQD. UNDER CERTAIN CNDTNS, SUCH AS(ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 22:SPRAYING, MECH PREFILTER MAY ALSO BE REQD. IN
CONFINED AREAS USE NIOSH/MSHA APPRVD AIR SUPPLIED RESP. IF (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21:TLV'S ARE EXCEEDED USE PROPERLY FITTED NIOSH/MSHA
APPRVD RESP W/APPROP PROT FILTER. REFER TO OSHA 29 CFR (ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22:1910.134 "RESP PROT" & "RESP PROT MANUAL &
GUIDELINE, AMERICAN INDUST HYGIENE ASSOC."
RTECS #:9999999ZZ
Ingred Name:VENT:MAY BE LISTED. REFER TO "INDUS VENT - A MANUAL FOR REC
PRACTICE" - ACGIH.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INGEST:CAN CAUSE GI IRRIT, NAUS
& VOMIT. ASPIR OF MATL INTO LUNGS MAY CAUSE CHEM PNEUM WHICH CAN BE
FATAL. INHAL:MAY CAUSE NOSE/THROAT IRRIT. HIGH CONCS MAY CAUSE
ACUTE CNS DEPRESS CHARACT BY HD CHS, DIZZ, NAUS & CONFUSN. EYE:MAY
CAUSE SEV IRRIT. SKIN:LIQ MATL MAY BE ABSORBED IN HARMFUL AMTS. MAY
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC
MONOGRAPHS, SUPP, VOL 7, PG 341, 1987:GRP 2A. NTP 7TH ANNUAL RPT ON
CARCINS, (SUPDAT)
Effects of Overexposure:HLTH HAZ:CAUSE DEFAT & IRRIT. CHRONIC:RPTD &
PRLNG OCCUP OVEREXP TO CRYSTALLINE SILICA MAY CAUSE SILICOSIS,
PROGRESSIVELY DIABLING LUNG DISEASE. OVEREXP TO XYLENE MAY CAUSE
INJURY TO LIVER, KIDNEYS &BLOOD. EXPOS TO METHYL ETHYL KETONE
MAYINHANCE NEUROTOX OF N-HEXANE & METHYL-N-BUTYL KETONE. THIS
SYNERGISTIC (SUPDAT)
Medical Cond Aggravated by Exposure:PREEXISTING RESPIRATORY CONDITIONS
MAY BE AGGRAVATED BY EXPOSURE TO CRYSTALLINE SILICA.
======================= First Aid Measures =======================
First Aid:INGEST:DO NOT INDUCE VOMIT. CALL POIS CTL CTR, HOSPITAL EMER
ROOM/MD IMMED. INHAL:REMOVE TO FRESH AIR IMMED. IF BRTHG HAS
STOPPED, GIVE ARTF RESP. KEEP WARM & QUIET. GET MED ATTN IMMED.
EYE:FLUSH W/LG AMTS OF WATER, LIFTING UPPER & LOWER LIDS OCCAS.
CONTINUE FOR AT LST 15 MINS. GET MED ATTN. SKIN:REMOVE CONTAM
CLTHG. WASH AFFECTED AREA W/SOAP & WATER. OBTAIN MED ATTN IF IRRIT
PERSISTS. (ING 16)
===================== Fire Fighting Measures =====================
Flash Point:24.0F,-4.4C
Lower Limits:SEE INGS
Upper Limits:SEE INGS
Extinguishing Media:USE NFPA CLASS B FIRE EXTINGS (CARBON DIOXIDE, ALL
PURPOSE DRY CHEM/ALCOHOL FOAM) DESIGNED TO EXTING FLAMM LIQ
(SUPDAT)
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
WATER MAY BE INEFT, BUT MAY BE USED TO COOL EXPOS CNTNRS TO PVNT
PRESS BUILD-UP & POSS AUTO-IGNIT/ (SUPDAT)
Unusual Fire/Explosion Hazard:DURING EMERGENCY CONDITIONS, OVEREXPOSURE
TO DECOMPOSITION PRODUCTS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE
IMMED APPARENT. OBTAIN MED ATTN. WARNING - FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP SPECTATORS AWAY. ELIM ALL IGNIT
SOURCES(FLAMES, HOT SURFS & SOURCES OF ELEC, STATIC/FRICTIONAL
SPKS). DIKE & CONTAIN SPILL W/INERT MATL(E.G. SAND, EARTH).
TRANSFER LIQS TO COVERED METAL CNTNRS FO R RECOVERY/DISP, OR REMOVE
W/INERT ABSORB.(ING 18)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE >115F (46C). STORE LG
QTYS IN COMPLIANCE W/OSHA 29 CFR 1910.106. DO NOT TAKE INTERNALLY.
CLOSE CNTNR AFTER EACH USE.
Other Precautions:DO NOT BREATHE SANDING DUST. EMPTY CNTNRS MUST NOT BE
WASHED & RE-USED FOR ANY PURPOSE. CNTNRS SHOULD BE GROUNDED &
BONDED TO RECEIVING CNTNR. DO NOT WELD, BRAZE/CUT EMPTY CNTNR.
NEVER USE PRESS TO EM PTY. DRUM IS NOT A PRESS VESSEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:PROPER SELECTION OF RESP PROT DEPENDS UPON MANY
FACTORS INCL DURATION/LEVEL OF EXPOS & CNDTNS OF USE. IN GEN EXPOS
TO ORG CHEMS SUCH AS THOSE CNTND IN THIS PROD MAY NOT REQ USE OF
RESP PROT IF USED IN WELL VENTILATED AREAS. IN (ING 20)
Ventilation:PROVIDE LOC EXHST VENT IN SUFFICIENT VOL & PATTERN SO AS TO
MAINTAIN EXPOS BELOW NUISANCE DUST LIMS & PELS WHICH(ING 24)
Other Protective Equipment:NOT LIKELY TO BE NEEDED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:26492 TT-E-529G. EXTING MEDIA:FIRES. POLYMER
FOAM IS PREF FOR LG FIRES. FIRE FIGHT PROC:EXPLO WHEN EXPOS TO
EXTREME HEAT. IF WATER IS USED, FOG NOZZ ARE PREF. EXPLAN OF CARCIN
:1994:ANTIC TO BE CARCIN. EFTS OF OVEREXP:EFTS HAS RSLTD IN
PERIPHERAL NEUROPATHY IN HUMANS. RPTS HAVE ASSOC (ING 10)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>175F,>79C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.4
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:41
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS. OXIDIZING MATERIALS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT (>115F (46C)) &
SOURCES OF IGNITION.
Hazardous Decomposition Products:BURNING, INCLUDING WHEN HEATED BY
WELDING OR CUTTING, WILL PRODUCE SMOKE, CARBON MONOXIDE & CARBON
DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS. THIS PRODUCT, IF DISCARDED DIRECTLY, WOULD BE
CLASSIFIED HAZ WASTE BASED ON ITS IGNITABILITY CHARACT, I.E. HAS
FLASH POINT OF 140F (60C) OR LESS. HAZ WASTE #:D001.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:STRONTIUM HYDROXIDE ANHYDROUS, 5478
CAGE:DO811
CAGE:DO811
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:STRONTIUM HYDROXIDE
CAS:18480-07-4
RTECS #:WK9100000
Fraction by Wt: 90-100%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NO EFFECTS OF OVEREXPOSURE WERE
DOCUMENTED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:CALL MD. INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
O*2/ARTF RESP) . INGEST:IF CONSCIOUS, IMMEDIATELY INDUCE VOMITING.
EYES:IMMEDIATELY FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINUTES. S
KIN:FLUSH W/WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
MOVE EXPOS CNTNRS FROM FIRE AREA IF IT CAN BE DONE W/OUT RISK. USE
WATER TO KEEP FIRE-EXPOS CNTNRS COOL.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT CLTHG.
WITH CLEAN SHOVEL, CAREFULLY PLACE MATL INTO CLEAN, DRY CNTNR &
COVER; REMOVE FROM AREA. FLUSH SPILL AREA W/WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED.
SUITABLE FOR ANY GENERAL CHEMICAL STORAGE AREA.
Other Precautions:WARNING! HARMFUL IF SWALLOWED. CAUSES IRRITATION.
AVOID CONTACT W/EYES, SKIN, CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCENTRATION IS HIGH, USE
APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR OR DUST MASK.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
FUME OR DUST LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:LAB COAT, UNIFORM, APRON ARE RECOMMENDED.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:707F,375C
Spec Gravity:3.63 (H*2O=1)
Solubility in Water:SLIGHT (0.1-1%)
Appearance and Odor:COLORLESS, DELIQUESCENT CRYSTALS.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE DOCUMENTED.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W ALL APPLICABLE FEDERAL, STATE &
LOCAL ENVIRONMENTAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:PRO-SEAL 706
Kit Part:Y
CAGE:6E409
CAGE:6E409
============= Composition/Information on Ingredients =============
Ingred Name:LEAD PEROXIDE
CAS:1309-60-0
RTECS #:OG0700000
Fraction by Wt: 75%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.05MG/M3
ACGIH TLV:0.15MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:MAX BLOOD LEAD LEVELS 40 MICRO-G/100G
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THE MOST SIGNIFICANT HEALTH HAZARD OF
LEAD DIOXIDE IS BY INHALATION OF AIRBORNE DUST PARTICLES. IN THIS
PRODUCT, LEAD DIOXIDE IS THOROUGHLY AND PERMANENTLY WETTED, AND
THEREFORE DOES NOT PRESENT A RI SK OF EXPOSURE TO DUST PARTICLES.
HOWEVER, INORGANIC PB COMPOUNDS GENERALLY ARE TOXIC BY INGEST,
ALTHOUGH NOT ABSORBED
Effects of Overexposure:ANEMIA, CENTRAL NERVOUS SYSTEM EFFECTS,
ADOMINAL COLIC OR KIDNEY FUNCTION LOSS CAN OCCUR AT BLOOD LEVELS OF
60 MICROGRAMS/ 100 GRAMS THE RECOMEMDED MAXIMUM IS 40 MICROGRAMS/
100 GRAMS
Medical Cond Aggravated by Exposure:OVEREXPOSURE TO ANY CHEMICAL MAY
RESULT IN AGGRAVATION OF MEDICAL CONDITIONS OR ALLERGIC REACTIONS.
======================= First Aid Measures =======================
First Aid:(EYES)- IMMEDIATELY FLUSH W/H20 FOR 15 MIN. IF IRRITATION
PERSISTS CONSULT A PHYSICIAN. (SKIN)-WASH THOROUGHLY WITH SOAP AND
WATER. (INHAL)-(INGEST)-CONSULT A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Extinguishing Media:WATER
Fire Fighting Procedures:USE SELF CONTAINEDBREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:OXIDIZER
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP UP SPILLED MATERIAL. CLEAN UP RESIDUE
WITH RAGS AND NON-FLAMMABLE SOLVENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:WASH THROUGHLY AFTER HANDLING AND
BEFORE SMOKING OR EATING. AVOID INGESTION.
Other Precautions:THIS PRODUCT CONTAINS A TOXIC CHEMICAL OR CHEMICALS
SUBJECT TO THE REQUIREMENTS OF SECTION 313 OF TITLE III SARA
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CONTACT LOCAL SAFETY/INDUSTRIAL HYGIENE OFFICE
TO DETERMINE IF RESPIRATORY PROTECTION IS REQUIRED
Ventilation:PROVIDE GOOD GENERAL AND/OR LOCAL EXHAUST VENTILATION TO
CONTROL AIRBORNE LEVELS BELOW THE EXPOSURE LIMITS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING, DRINKING OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
THIS IS PART A OF A 2 PART KIT. SEE P/N IND B, THIS NSN,
8030-00-965-2444 FOR ADDITIONAL INFORMATION.
================== Physical/Chemical Properties ==================
Spec Gravity:2.6
Solubility in Water:NEGLIGBLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:0%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:SMOKE; SOOT; CARBON MONOXIDE; CARBON
DIOXIDE; LEAD COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH ALL
APPLICABLE LOCAL, STATE AND FEDERAL REGULATIONS. COORDINATE WITH
SUPPORTING INSTALLATION AND/OR MACOM ENVIRONMENTAL OFFICE PRIOR TO
DISPOSAL
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:LAB ALGICIDE, 004-300040
CAGE:IO526
CAGE:IO526
CAGE:58378
============= Composition/Information on Ingredients =============
Ingred Name:COPPER (II) CARBONATE HYDROXIDE(2:1:2); (COPPER CARBONATE)
CAS:12069-69-1
RTECS #:GL6910000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHANOL, 2-AMINO-; (MONOETHANOLAMINE)(MFR CAS: 44-43-5)
CAS:141-43-5
RTECS #:KJ5775000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHANOL, 2,2',2''-NITRILOTRI-; (TRIETHANOLAMINE) (MFR'S
INVALID CAS#: 107-71-6)
CAS:102-71-6
RTECS #:KL9275000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BIS(2-CHLOROETHYL)ETHER-N,N,N',N'-TETRAMETHYL-ETHYLENE
DIAMINE COPOLYMER;(N-ALKYL (50%C14,40%C12,10%C13) DIMETHYL(ING 5)
CAS:31075-24-8
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ING 4: BENZYL AMMONIUM CHLORIDE.
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRIT TO SKIN & EYES. VAPORS OR MIST
MAY CAUSE IRRITATION W/PAIN, COUGHING AND DISCOMFORT EYES, NOSE,
THROAT & CHEST.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF FRESH WATER FOR AT LEAST 15 MINS. GET
MED ATTN IMMED. SKIN: WASH W/PLENTY OF WATER FOR AT LEAST 15
MINUTES. INHAL: REMOVE TO FRESH AIR. INGEST: GIVE LARGE AMOUNTS OF
MILK, EGG WHITES, GELATIN OR WATER. GET MED ATTN IMMED.
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, WATER/POLYMER FOAM
FOR LARGE FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH INERT MATERIAL AND STORE IN CLOSED
CONTAINER. FLUSH SPILL ARE HEAVILY WITH WATER. VENT AREA.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL DRY PLACE. KEEP AWAY
FROM STRONG ACIDS.
Other Precautions:AVOID CONTAMINATION WITH FOOD. KEEP OUT REACH OF
CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN.
Ventilation:MECHANICAL EXHAUST FAN.
Other Protective Equipment:EMERG EYEWASH AND DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPEC GRAV: 1.200 @ 27 C(80.6F).
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:SUPDAT
Solubility in Water:SOLUBLE
Appearance and Odor:BLUE VISCOUS LIQUID; SLIGHT ODOR.
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/STRONG ACIDS & NITRITES.
Stability Condition to Avoid:THERMAL DECOMPOSITION MAY CAUSE OXIDES OF
CARBON AND NITROGEN.
Hazardous Decomposition Products:NONE INDICATED.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR CONTACT AUTHORIZED WASTE HANDLER
FOR DISPOSAL. FOLLOW LOCAL, STATE & FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:POTASSIUM BROMIDE (0505)
CAGE:DO880
CAGE:37940
CAGE:DO880
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM BROMIDE (CAS #7758-02-3)
CAS:7758-02-3
RTECS #:TS7650000
Fraction by Wt: 100%
===================== Hazards Identification =====================
Effects of Overexposure:DEPRESSION,EMACIATION & IN SEVERE
CASES,PSYCHOSIS & MENTAL DETERIORATION.
======================= First Aid Measures =======================
First Aid:EYE-FLUSH WITH LARGE AMOUNTS WATER & CALL DOCTOR.SKIN-WASH
WITH LARGE QUANTITIES WATER.INGESTION-CALL PHYSICIAN & INDUCE
VOMITING.
===================== Fire Fighting Measures =====================
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CNTND BRTHG APP
Unusual Fire/Explosion Hazard:WHEN HEATED TO DECOMPOSITION,EMITS TOXIC
FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:CAREFULLY SCOOP UP & PLACE IN A CONTAINER
SUITABLE FOR SHIPMENT TO AN APPROVED DISPOSAL AREA.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY PALCE.KEEP CONTAINER
TIGHTLY CLOSED.WASH THOROUGHLY AGTER HANDLING.SEPARATE FROM
OXIDIZERS.
Other Precautions:AVOID BREATHING DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DUST MASK/DUST RESPIR
Ventilation:MECHANICAL (GENERAL/LOCAL EXHAUST)
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
MSDS DATE-2/80.ORAL-HUMAN LDLO=500 MG/KG.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:1435 C
Spec Gravity:2.75
Solubility in Water:53%
Appearance and Odor:WHITE CRYSTALLINE POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BROMINE TRIFLUORIDE,ACIDS & STRONG OXIDIZERS.
Hazardous Decomposition Products:WHEN HEATED TO DECOMPOSITION EMITS
TOXIC FUMES OF BROMIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:BUFFER SOLUTION PH 10, 41118, SB1161
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM CARBONATE
CAS:584-08-7
RTECS #:TS7750000
Fraction by Wt: 0.6%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POTASSIUM HYDROXIDE (CERCLA). LD50: (ORAL, RAT) 273 MG/KG.
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 0.2%
OSHA PEL:2 MG/M3, C
ACGIH TLV:2 MG/M3, C
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:DISODIUM DIHYDROGEN ETHYLENEDIAMINETETRACETATEDIHYDRATE
CAS:6381-92-6
RTECS #:AH4410000
Fraction by Wt: 1.0%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: BALANCE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POTASSIUM TETRABORATE; (POTASSIUM BORATE)
CAS:12228-88-5
Fraction by Wt: 0.4%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 2
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: MAY CAUSE EYE IRRITATION. SKIN:
MAY CAUSE MILD SKIN IRRITATION. LOW HAZARD FOR USUAL INDUSTRIAL
HANDLING. INGESTION: LOW HAZARD FOR USUAL INDUSTRIAL HANDLING. MAY
CAUSE GASTRIC DISTURBANCES AND E LECTROLYTIC IMBALANCE. INHALATION:
MAY CAUSE RESPIRATORY TRACT IRRITATION. LOW HAZARD FOR USUAL (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: INDUSTRIAL HANDLING. CHRONIC: NO
INFORMATION FOUND. TARGET ORGANS: NONE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: GET MEDICAL AID. GENTLY LIFT EYELIDS AND FLUSH
CONTINUOUSLY WITH WATER FOR AT LEAST 15 MINUTES. SKIN: GET MEDICAL
AID IF IRRITATION DEVELOPS OR PERSISTS. FLUSH SKIN WITH PLENTY OF
SOAP AND WATER . INGEST: IF VICTIM IS CONSCIOUS & ALERT, GIVE 2-4
CUPFULS OF MILK OR WATER. GET MEDICAL AID. INHAL: GET MEDICAL AID
IMMEDIATELY. REMOVE FROM EXPOSURE TO FRESH AIR IMMEDIATELY. IF NOT
(SUPDAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:SUBSTANCE IS NONCOMBUSTIBLE; USE AGENT MOST
APPROPRIATE TO EXTINGUISH SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTIVE EQUIPMENT AS
INDICATED. ABSORB SPILL WITH INERT MATERIAL (EG DRY SAND OR EARTH),
THEN PLACE INTO A CHEMICAL WASTE CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE.
Other Precautions:USE WITH ADEQUATE VENTILATION. AVOID CONTACT WITH
EYES. KEEP CONTAINER TIGHTLY CLOSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW OSHA RESPIRATOR REGULATIONS FOUND IN 29
CFR 1910.134. ALWAYS USE A NIOSH APPROVED RESPIRATOR WHEN
NECESSARY.
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT TO CONTROL
AIRBORNE LEVELS.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
WEAR APPROPRIATE PROTECTIVE CLOTHING TO MINIMIZE CONTACT WITH SKIN.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: BREATHING, GIVE ARTIFICIAL RESPIRATION. NOTES TO MD:
TREAT SYMPTOMATICALLY & SUPPORTIVELY. ANTIDOTE: NONE REPORTED.
================== Physical/Chemical Properties ==================
Evaporation Rate & Reference:1.0 (ETHER =1)
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NOT AVAILABLE.
Stability Condition to Avoid:NONE REPORTED.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE AND LOCAL REGULATIONS. NOT LISTED AS A MATERIAL BANNED FROM
LAND DISPOSAL ACCORDING TO RCRA.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:POTASSIUM CARBONATE, ANHYDROUS, 3015
CAGE:DO803
CAGE:DO803
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM CARBONATE; (POTASSIUM CARBONATE, ANHYDROUS)
CAS:584-08-7
RTECS #:TS7750000
Fraction by Wt: 99-100%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT) 1870 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: IRRITATION OF UPPER
RESPIRATORY TRACT. SKIN CONTACT: SEVERE IRRITATION OR BURNS. EYE
CONTACT: SEVERE IRRITATION OR BURNS. INGESTION: IRRITATION AND
BURNS TO MOUTH AND STOMACH. TARGE T ORGANS: EYES, SKIN, MUCOUS
MEMBRANES.CHRONIC: NONE LISTED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE IDENTIFIED.
======================= First Aid Measures =======================
First Aid:INGEST: CALL PHYS. IF SWALLOWED, DO NOT INDUCE VOMIT. IF
CONSCIOUS, GIVE LG AMTS OF WATER. FOLLOW W/DILUTED VINEGAR, FRUIT
JUICE/WHITES OF EGGS BEATEN W/WATER. INHAL: REMOVE TO FRESH AIR. IF
NOT BRTHG , GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE OXYG. PROMPT
ACTION IS ESSTNL. SKIN: IMMED FLUSH W/PLENTY OF WATER FOR @ LST 15
MINS WHILE REMOVING CONTAMD CLTHG & SHOES. WASH CLTHG BEFORE
RE-USE. (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NOTE: DECOMPOSES AT BOILING POINT.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH APPRVD SCBA & FULL PROT CLTHG. WITH
CLEAN SHOVEL, CAREFULLY PLACE MATERIAL INTO CLEAN, DRY CONTAINER
AND COVER; REMOVE FROM AREA. FLUSH SPILL AREA WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED.
SUITABLE FOR ANY GENERAL CHEMICAL STORAGE AREA. DO NOT STORE NEAR
ACIDS. IRRITANT. AVOID CONT W/EYES, SKIN, CLOTHING.
Other Precautions:AVOID BREATHING DUST. KEEP IN TIGHTLY CLSD CONTAINER.
USE W/ADEQUATE VENTILATION. CAUSES SEVERE IRRITATION. MODERATELY
DESTRUCTIVE TO TISSUE. HARMFUL IF SWALLOWED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCENTRATION IS HIGH, USE AN NIOSH
APPRVD APPROP RESPIRATOR OR DUST MASK.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
FUME OR DUST LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
UNIFORM.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
FIRST AID PROC: EYE: IMMED FLUSH W/PLENTY OF WATER FOR @ LST 15 MINS.
EYE PROT:& FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:1635F,891C
Spec Gravity:2.29 (H*2O=1)
Solubility in Water:APPRECIABLE (>10%)
Appearance and Odor:WHITE GRANULES. ODORLESS.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, STRONG ACIDS.
Stability Condition to Avoid:MOISTURE, DUSTING, HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE, AND LOCAL ENVIRONMENTAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:24-0108 OXYGEN "R" CELL SENSOR ASSEMBLY (O2)
Preparer's Name:MSDS COORDINATOR
CAGE:05083
CAGE:05083
============= Composition/Information on Ingredients =============
Ingred Name:MANUFACTURER LISTS NOTHING UNDER "INGREDIENTS" IMPLYING
THAT THERE ARE NO HAZARDOUS INGREDIENTS PER HAZ COM STANDARD.
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NONE SPECIFIED BY MANUFACTURER.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:NONE SPECIFIED BY MANUFACTURER.
===================== Fire Fighting Measures =====================
Extinguishing Media:NONE SPECIFIED BY MANUFACTURER.
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PER LETTER FAXED 26 OCTOBER 1995, THE ITEM DOES NOT REQUIRE AN MSDS
UNDER 1910.1200.
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:OXYGEN SENSOR.
================= Stability and Reactivity Data =================
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:NONE SPECIFIED BY MANUFACTURER.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:MIL-P-698A
CAGE:33151
CAGE:33151
============= Composition/Information on Ingredients =============
Ingred Name:PIGMENTS
Fraction by Wt: 20.5%
Ingred Name:CATALYST
Ingred Name:VEHICLE
Ingred Name:SOLVENTS
Fraction by Wt: 37.5%
ACGIH TLV:200 PPM
Ingred Name:ADDITIVES
===================== Hazards Identification =====================
Effects of Overexposure:SKIN,EYE
IRRITANT,ANESTHESIA,HEADACHE,DIZZINESS,NAUSE,ETC.
======================= First Aid Measures =======================
First Aid:SKIN CONTACT-WASH WITH MILD SOAP AND WATER.EYE CONTACT FLUSH
EYES WITH PLENTY OF WATER.INHALATION-REMOVE TO FRESH AIR,RESTORE
BREATHING IF REQUIRED.
===================== Fire Fighting Measures =====================
Flash Point:111F,44C TCC
Lower Limits:1.0
Upper Limits:6.0
Extinguishing Media:FOAM,CO*2,STEAM,WATER FOG,DRY CHEMICAL
Fire Fighting Procedures:EXCLUDE AIR,DO NOT USE WATER,CONSULT FIRE
MARSHAL
Unusual Fire/Explosion Hazard:VAPOR FORMS EXPLOSIVE MIXTURE W/AIR
BETWEEN UPPER AND LOWER EXPLOSIVE LIMITS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNITION SOURCES.VENTILATE AREA
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID IGNITION SOURCES,SPLASH
FILLING,EXCESSIVE HEAT.PROVIDE ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ORGANIC CANNISTER MASK OR AIR PACK
Ventilation:MECHANICAL W/APPROVED CLASS D EXPLOSION PROOF MOTORS/SWITCH
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:323F,162C
Vapor Pres:1
Vapor Density:5.0
Spec Gravity:0.777
Evaporation Rate & Reference:< BUTYL ACETATE
Solubility in Water:NEGLIGIBLE
Percent Volatiles by Volume:56
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO CO*2 WHEN COMBUSTED
==================== Disposal Considerations ====================
Waste Disposal Methods:EVAPORATE OR FLUSH WITH WATER IN A WELL
VENTILATED AREA.USE OIL SEWER IF AVAILABLE OR REMOVE TO A
CONTAINER
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:IODINE SOLUTION
Preparer's Name:PETER WOLPERT
CAGE:83628
CAGE:83628
============= Composition/Information on Ingredients =============
Ingred Name:IODINE
CAS:7553-56-2
RTECS #:NN1575000
Fraction by Wt: 3%
OSHA PEL:0.1 PPM, C
ACGIH TLV:0.1 PPM, C
Ingred Name:POTASSIUM IODIDE
CAS:7681-11-0
RTECS #:TT2975000
Fraction by Wt: 20-50%
Ingred Name:DISTILLED WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: TO 100%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF SWALLOWED, INHALED, OR
ABSORBED THROUGH SKIN. MATERIAL IS EXTREMELY DESTRUCTIVE TO TISSUE
OF MUCOUS MEMBRANES AND UPPER RESPIRATORY TRACT, EYES AND SKIN.
SYMPTOMS OF EXPOSURE MAY INCLUDE BU RNING SENSATION, COUGHING,
WHEEZING, LARYNGITIS, SHORTNESS OF BREATH, HEADACHE, NAUSEA AND
VOMITING. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HEALTH HAZARDS: EXPOSURE CAN CAUSE STOMACH
PAINS, VOMITING AND DIARRHEA, SKIN EXPOSURE MAY CAUSE STAINS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING GIVE
ARTIFICIAL RESPIRATION PREFERABLY MOUTH-TO-MOUTH. IF BREATHING IS
DIFFICULT GIVE OXYGEN. CALL PHYSICIAN. INGESTION: GIVE WATER TO
DRINK AND GET M EDICAL ATTENTION. SKIN: WASH WITH SOAP AND WATER.
GET MEDICAL ADVICE IF IRRITATION DEVELOPS. EYE: IMMEDIATELY FLUSH
WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. CALL PHYSICIAN IF
IRRITATION DEVELOPS.
===================== Fire Fighting Measures =====================
Extinguishing Media:NOT CONSIDERED TO BE A FIRE HAZARD. USE ANY MEANS
SUITABLE FOR EXTINGUISHING SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:WHEN HEATED TO DECOMPOSITION, IT MAY EMIT
TOXIC FUMES OF IODINE, AND IODINE COMPOUNDS WHICH MAY REACT WITH
REDUCING MATERIAL.
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA OF SPILL OR LEAK. WEAR NIOSH/MSHA
SPILLS WITH DRY ABSORBENT. CONTAINERIZE UNUSABLE MATL FOR DISP IN
AN APPROVED WASTE FACILIT Y. WASH SPILL SITE AFTER MAL PICK-UP
ISCOMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY VENTILATED AREA.
PROTECT FROM PHYSICAL DAMAGE. PROTECT FROM FREEZING.
Other Precautions:NONE INDICATED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED DUST/MIST RESPIRATOR. UNDER
NORMAL CONDITIONS RESPIRATORY PROTECTION NOT REQUIRED.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION.
Other Protective Equipment:SAFETY SHOWER AND EYEWASH BATH.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FACESHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Solubility in Water:INFINITELY MISCIBLE
Appearance and Odor:REDDISH-BROWN LIQUID, SLIGHT IODINE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
(AS IODINE) MAGNESIUM, ZINC, AMMONIA, ALUMINUM, ANTIMONY, REACTS
VIOLENTLY WITH ACETALDEHYDE. CORRODES STEEL.
Stability Condition to Avoid:AVOID PHYSICAL SHOCK OR DAMAGE. GLASS
AMPOULE IS VERY FRAGILE.
Hazardous Decomposition Products:WHEN HEATED TO DECOMPOSITION, IT EMITS
TOXIC FUMES OF IODINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE, AND LOCAL ENVIRONMENTAL REGULATIONS.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: ARESCO-BOND 526 ACTIVATOR
Cage: IO920
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 34363
Box: 517
Cage: IO920
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHAL:ALLERGIES &/OR ASTHMA & NASAL IRRITATION MAY
BE AGGRAVATED BY EXPOSURE, ERYTHMA, EDEMA. SKIN CONTACT:WHEN HEATED WILL
CAUSE BURNS. EYE CONTACT:BURNING, ITCHING, REDNESS FROM HEATED FUMES. INGEST
:NO KNOWN ADVERSE EFFECTS, BUT COULD BEIRRITATING TO DIGESTIVE SYSTEM.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: ALLERGIES &/OR ASTHMA & NASAL
IRRITATION MAY BE AGGRAVATED BY EXPOSURE.
First Aid: INHAL:REMOVE TO FRESH AIR AT ONCE IF BRTHG ON OWN. IF BRTHG HAS
STOPPED APPLY ARTF RESP. GET MED ATTN. SKIN:PROMPTLY WASH THORO W/MILD SOAP
& WATER. REMOVE CONTAM CLTHG. EYES:FLUSH IMMED (W/IN 20 SEC) W/WATER FOR
AT LST 15 MINS. GET MED ATTN. INGEST:GET MED ATTN. NEVER GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS PERSON.
=======================================================
Handling and Disposal
=======================================================
& IMPERVIOUS CLOTHING. ABSORB & TRANSFER TO CLOSABLE CONTAINER FOR
DISPOSAL. FLUSH CONTAMINATED AREA W/SOAP & WATER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
REGULATIONS.
Handling And Storage Precautions: STORE AT ROOM TEMPERATURE.
Other Precautions: ALL SAFETY OR HAZARD DATA AVAILABLE WILL BE RELEASED IN
EVENT OF MEDICAL EMERGENCY OR AS REQUESTED BY AUTHORIZED AGENTS W/IN
GUIDELINE OF HAZARD COMMUNICATION STD.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: >315F,>157C
Extinguishing Media: CARBON DIOXIDE FOAM, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). USE WATER SPRAY TO COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard: VAPORS & FUMES FROM BURNING CAUSE
RESPIRATORY PROBLEMS. HANDLE AS A COMBUSTIBLE LIQUID.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC VAPORS
IF CONCENTRATION IS OVER 5 PPM.
Ventilation: LOCAL EXHAUST.
Other Protective Equipment: NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices: WASH HANDS & FACE IMMEDIATELY AFTER USE.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
B.P. Text: 390F,199C
Vapor Pres: <0.1 @160F
Vapor Density: 9
Spec Gravity: 0.97
Solubility in Water: MISCIBLE
Appearance and Odor: YELLOW TO RED COLORED LIQUID; AMINE ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HIGH HEAT & MOISTURE.
Materials To Avoid: NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products: CARBON DIOXIDE, CARBON MONOXIDE, NITRIC
OXIDE, NITROGEN DIOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: ARESCO-BOND 526 ACTIVATOR
Cage: IO920
Assigned IND: Y
Company Name: ARESCO PRODUCTS INC
Street: 23 SNOWDEN AVE
Zipcode: 10562
Label Required IND: Y
Date Of Label Review: 11/22/1994
Status Code: C
Label Date: 11/22/1994
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE:INHAL:ALLERGIES &/OR ASTHMA
& NASAL IRRITATION MAY BE AGGRAVATED BY EXPOSURE, ERYTHMA, EDEMA. SKIN
CONTACT:WHEN HEATED WILL CAUSE BURNS. EYE CONTACT:BURNING, ITCHING, REDNESS
FROM H EATED FUMES. INGEST:COULD BE IRRITATINGTO DIGESTIVE SYSTEM.
CHRONIC:NONE LISTED BY MANUFACTURER.
=======================================================
| 1 |
gloves_mandatory
|
Product ID:BRILLIANCE NEUTRAL DETERGENT/ODOR COUNTERAC
CAGE:89044
CAGE:89044
============= Composition/Information on Ingredients =============
Ingred Name:NONYLPHENOL ETHOXYLATE
CAS:9016-45-9
RTECS #:MD0900000
Fraction by Wt: 4.0%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EFFECTS OF OVEREXPOSURE TO CONCENTRATE
- SKIN/EYES: MAY IRRITATE. INGESTION: MAY CAUSE STOMACH DISTRESS,
NAUSEA OR VOMITING.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMEDIATELY W/PLENTY COOL RUNNING WATER. REMOVE
CONTACTS & CONTINUE FLUSHING 15 MINUTES. SKIN: FLUSH W/PLENTY COOL
RUNNING WATER. WASH THOROUGHLY W/SOAP & WATER. INGESTION: RINSE
MOUTH, TH EN DRINK 1 OR 2 LARGE GLASSES WATER. DONOT INDUCE
VOMITING. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. IF
IRRITATION/DISCOMFORT PERSISTS, CALL DR.
===================== Fire Fighting Measures =====================
Flash Point:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP. DIKE/DAM LARGE SPILLS. PUMP TO
CONTAINERS OR SOAK UP ON INERT ABSORBENT. FLUSH RESIDUE TO SANITARY
SEWER.
======================Handling and Storage ======================
Handling and Storage Precautions:NA
Other Precautions:NA
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NA
Ventilation:NA
Other Protective Equipment:NA
Supplemental Safety and Health
NK
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE W/FEDERAL, STATE, LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
=======================================================
NIIN: 00-295-7685
Product ID: 60089, 5 OZ V724 ELECT INSUL SILI CPD
Cage: TO876
=======================================================
Contractor Summary
=======================================================
Cage: TO876
=======================================================
Item Description Information
=======================================================
Item Manager: S9G
Item Name: SILICONE COMPOUND
Specification Number: MIL-C-8660
Unit of Issue: CN
Quantitative Expression: 00000000010LB
UI Container Qty: 1
Type of Container: CAN
=======================================================
Ingredients
=======================================================
Cas: 63148-62-9
RTECS #: JT6484500
% low Wt: 90.
% high Wt: 95.
------------------------------
Cas: 112945-52-5
RTECS #: VV7310000
% low Wt: 5.
% high Wt: 10.
=======================================================
Health Hazards Data
=======================================================
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: PRIMARY ROUTE: EYES. TEMPORARY EYE IRRITATION
Signs And Symptions Of Overexposure: TEMPORARY EYE IRRITATION
Medical Cond Aggravated By Exposure: NONE KNOWN.
First Aid: INGESTION: DO NOT INDUCE VOMITING. KEEP INDIVIDUAL CALM. OBTAIN
MEDICAL ATTENTION. INHALATION: DOES NOT APPLY. SKIN: WASH WITH SOAP &
WATER. EYE: FLUSH EYES WITH WATER FOR AT LEAST 15 MINUTES. IRRITAT ION IS
TRANSIENT. IF IT PERSISTS, OBTAIN MEDICAL ATTENTION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SCRAPE UP BULK-REMOVE FILM WITH INERT ABSORBENT
&/OR HYDROPHOBIC SOLVENT. IF SOLVENT IS USED, OBSERVE ALL HANDLING
PROCEDURES FOR SOLVENT.
Waste Disposal Methods: INCINERATE FOLLOWING EPA AND LOCAL REGULATIONS
Handling And Storage Precautions: STORAGE: FOR BEST PERFORMANCE STORE BELOW 90
DEG F, IN A CLOSED CONTAINER. HANDLING: AVOID PROLONGED SKIN CONTACT. KEEEP
AWAY FROM EYES. BE NEAT-CAN CAUSE SLOPPERY CONDITIONS.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: COC
Flash Point: >260.C, 500.F
Extinguishing Media: CARBON DIOXIDE, WATER, & DRY POWDER.
Unusual Fire/Explosion Hazard: NONE KNOWN.
=======================================================
Control Measures
=======================================================
Ventilation: LOCAL VENTILATION MAY BE DESIRED FOR PROLONGED USE IN A CONFINED
AREA.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: V5
B.P. Text: NOT AVAILABLE
Vapor Pres: NOT AVAILABLE
Spec Gravity: 1.03
PH: NOT ESTABLISHED
Evaporation Rate & Reference: NOT AVAILABLE
Solubility in Water: > 1%
Appearance and Odor: TRANSLUCENT-LIGHT WHITE PASTE. LITTLE OR NO ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: TEMPERATURE OVER 550F.
Materials To Avoid: STRONG ACIDS & ALKALIS, STRONG OXIDIZING AGENTS SUCH AS
PEROXIDES & AMMONIUM NITRATE.
Hazardous Decomposition Products: BY FIRE OR THERMAL DECOMP: OXIDES OF SILICON,
CARBON & DUST.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: WILL NOT OCCUR.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
Transport Information: DOT, 49 CFR 172: UNRESTRICTED. IATA: UNRESTRICTED.
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 154270
Product ID: 60089, 5 OZ V724 ELECT INSUL SILI CPD
Review Date: 07/31/2000
Net Unit Weight: 10 LBS
Multiple KIT Number: 0
Unit Of Issue: CN
Container QTY: 1
Type Of Container: CAN
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: 60089, 5 OZ V724 ELECT INSUL SILI CPD
Cage: TO876
Assigned IND: Y
Company Name: LOCTITE CORPORATION
Street: 705 NORTH MOUNTAIN ROAD
Zipcode: 06111
Label Required IND: Y
Date Of Label Review: 07/31/2000
Status Code: A
Origination Code: F
Skin Protection IND: YES
Signal Word: CAUTION
Health Hazard: None
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:47 3874 MP ENAMEL BROWN
CAGE:06758
CAGE:06758
CAGE:23526
============= Composition/Information on Ingredients =============
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; PETROLEUM DISTILLATE,
HYDROTREATED ,(MINERAL SPIRITS)
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 40%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:RED IRON OXIDE/IRON (III) OXIDE/FERRIC OXIDE/YELLOW FERRIC
OXIDE/METAL OXIDE/YELLOW IRON OXIDE/IRON OXIDE PIGMENT/IRON
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 5%
OSHA PEL:10 MG/CUM
ACGIH TLV:5 MG/CUM (FE)
Ingred Name:VOL ORGANIC CMPD: 414 GRAMS/LITER
RTECS #:9999999VO
Ingred Name:WEIGHT PER GALLON IN POUNDS: 3.46
RTECS #:9999999WG
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: HARMFUL. MAY AFFECT THE
BRAIN/NERVOUS SYSTEM/RESPIRATORY SYSTEM, RESPIRATORY IRRITATION.
PROLONGED EXPOSURE TO RESPIRABLE CRYSTALLINE QUARTZ MAY CAUSE
DELAYED LUNG INJURY (SILICOSIS). OVER EXPOSURE TO SOLVENTS MAY
CAUSE PERMANANT BRAIN & NERVOUS SYSTEM DAMAGE. EYES: IRRITATION.
SKIN: IRRITATION/ABSORPTION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: DIZZINESS, HEADACHE, NAUSEA,
SHORTNESS OF BREATH.
Medical Cond Aggravated by Exposure:ANY RESPIRATORY OR SKIN CONDITION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMEDIATELY W/PLENTY OF WATER FOR AT LEAST 15
MINS. SKIN: WASH THOROUGHLY W/SOAP & WATER. INHALATION: REMOVE TO
FRESH AIR. INGESTION: OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:104F
Lower Limits:1%
Upper Limits:37%
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, OR WATER FOG
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS OR AIR
MASKS. CONTAINERS EXPOSED TO FIRE SHOULD BE KEPT COOL W/WATER
SPRAY.
Unusual Fire/Explosion Hazard:CONTAMINATED RAGS/WIPES/SAWDUST MAY CATCH
FIRE SPONTANEOUSLY.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. AVOID BREATHING OF VAPORS. USE
SCBA OR AIRMASK FOR LARGE SPILLS IN A CONFINED AREA. AVOID CONTACT
W/EYES. STORE WASTE UNDER WATER IN CLOSED METAL CONTAINERS UNTIL
DISPOSED.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM IGNITION SOURCE. KEEP
CONTAINER CLOSED WHEN NOT IN USE. DON'T STORE >120F. EMPTY
CONTAINERS MAY CONTAIN PRODUCT RESIDUE (FLAMMABLE VAPORS).
Other Precautions:DON'T CUT/PUNCTURE/WELD ON/NEAR CONTAINER. OBSERVE
ALL LABEL WARNINGS. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING & INHALING THE CONTENTS MAY BE HARMFUL OR FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE, PROPERLY FITTED RESPIRATOR
(NIOSH/MSHA APPROVED) DURING & AFTER APPLICATION UNLESS AIR
MONITORING LEVELS ARE BELOW APPLICABLE LIMITS.
Ventilation:REQUIRED FOR SPRAYING OR IN CONFINED AREA, VENTILATION
EQUIPMENT SHOULD BE EXPLOSION PROOF.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:315F
Vapor Pres:2
Vapor Density:5.1
Spec Gravity:1.01
Evaporation Rate & Reference:(BU AC = 1): 0.1
Solubility in Water:INSOLUBLE
Appearance and Odor:NORMAL FOR A COATINGS PRODUCT.
Percent Volatiles by Volume:52.62
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:IGNITION SOURCES, TEMPS >120F
Hazardous Decomposition Products:HALIDES, CO, CO2, METAL OXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN CHEMICAL DISPOSAL AREA OR IN A MANNER
THAT COMPLIES W/LOCAL, STATE, & FEDERAL REGULATIONS. DON'T
INCINERATE CLOSED CONTAINERS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:INTERGARD EPOXY INTERMEDIATE LT GRAY, FAJ03
CAGE:26351
CAGE:26351
============= Composition/Information on Ingredients =============
Ingred Name:METHYL N-AMYL KETONE
CAS:110-43-0
RTECS #:MJ5075000
Fraction by Wt: 20-25%
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9192
Ingred Name:EPOXY RESIN ERL-2795; (EPOXY RESIN)
CAS:25068-38-6
RTECS #:KC2100000
Fraction by Wt: 5-10%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:IRRITATION MAY OCCUR.
SKIN:IRRITATING. MAY RESULT IN DERMATITIS. MAY CAUSE SENSITIZATION
OR OTHER ALLERGIC RESPONSES. INHAL:MAY CAUSE IRRITATION. INGEST:MAY
CAUSE GI IRRITATION. CHRONIC OVEREXPOS URE TO OR MISUSE OF,
SOLVENTS HAS BEEN LINKED TO PERMANENT BRAIN/NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:SKIN AND RESPIRATORY CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH IMMEDIATLEY WITH COPIOUS QUANTITIES OF WATER FOR
AT LEAST 15 MINUTES. GET MD ATTENTION IMMEDIATELY. SKIN:REMOVE
CONTAMINATED CLOTHING, WASH SKIN WITH PLENTY OF SOAP AND WATER.
LAUNDER CLOTH ES BEFORE REUSE. INHAL:REMOVE TO FRESH AIR. GET MD
ATTENTION IMMEDIATELY. INGEST:CALL MD IMMEDIATELY TO DETERMINE
WHETHER OR NOT TO INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point:108F,42C
Lower Limits:1.1%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:CLOSED CONTAINER MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT. USE NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:SMOTHER FLAMES W/ONE OF THE ABOVE
EXTINGUISHING MEDIA. WATER MAY BE USED TO COOL UNOPENED CONTR, BUT
MUST NOT BE USED AS AN EXTINGUISHING MEDIA. TAKE (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
INHALATION OF VAPORS. VENTILATE AREA. CLEAN UP WITH ABSORBANT
MATERIALS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN BUILDING DESIGNED/PROT FOR
STORAGE OF LIQUID.
Other Precautions:AVOID BRTHG DUST/CHIPS FROM SANDING/BLASTING SURFACES
COATED W/THIS PROD.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN OUTDOOR/OPEN AREAS, W/UNRESTRICTED VENT USE
NIOSH/MSHA APPROVED FILTER RESP TO REMOVE SOLID AIR-BORNE PARTICLES
OF OVERSPRAY DURING SPRAY APPLICATN. IN RESTRICTED VENT AREAS,
NIOSH/MSHA APPROVED RE SP IN ACCORDANCE W/29 CFR 1910. (SUPDAT)
Ventilation:PROVIDE SUFFICIENT VENT IN VOLUME/PATTERN, TO KEEP TLV/LEL
OF HAZ INGRED BELOW LIMITS, AND TO REMOVE DECOMP (SUPP DATA)
Other Protective Equipment:WEAR APPROPRIATE IMPERVIOUS PROTECTIVE
CLOTHING TO PREVENT SKIN CONTACT. EMERGENCY EYE WASH AND DELUGE
SHOWER .
Work Hygienic Practices:REMOVE AND WASH SOILED CLOTHING BEFORE REUSE.
WASH HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health
EXPLOS HAZ:CARE TO PREVENT SPREAD OF BURNING LIQUID WITH WATER. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT. RESP PROT:134
TO REMOVE A COMBINATION OF PARTICULATES AND VAPORS. VENT:PRODU CTS
DURING WELDING OR FLAME CUTTING ON SURFACES COATED WITH THIS
PRODUCT.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:300F,149C
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:25
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS.
Stability Condition to Avoid:NONE KNOWN UNLESS OTHERWISE NOTED.
Hazardous Decomposition Products:CO, CO2, HYDROCARBON FRAGMENTS,
ALDEHYDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGUALATIONS. DO NOT INCINERATE UNOPENED CONTAINERS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:PERCHLOROETHYLENE
CAGE:GO264
CAGE:GO264
CAGE:77902
============= Composition/Information on Ingredients =============
Ingred Name:PERCHLOROETHYLENE (TETRACHLOROETHYLENE) (SARA III)
CAS:127-18-4
RTECS #:KX3850000
Fraction by Wt: 99%
OSHA PEL:100 PPM
ACGIH TLV:25PPM/100,A3 STEL;94
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Effects of Overexposure:INHAL:MAY CAUSE DIZZINESS,DRUNKENESS & DEATH.
EYE & SKIN CONT:IRRITATION & POSSIBLE BURN
======================= First Aid Measures =======================
First Aid:INHAL:MOVE SUBJ TO FRESH AIR,KEEP WARM, ADMIN ART RESPIRATION
AS NEEDED. EYE & SKIN CONTACT:FLUSH PROMPTLY WITH LARGE AMTS WATER-
15 MIN, CONSULT PHYSICIAN IF IRRITATION IS APPARENT. IF INGESTED-DO
NO T INDUCE VOMITING. GET PROMPT MED ATTENTION.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:WEAR BUREAU OF MINES/NIOSH APP BREATHING
APPARATUS
Unusual Fire/Explosion Hazard:HCL,PHOSGENE & CHLORINE MAY EVOLVE UNDER
FIRE
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILLS-ABSORB WITH RAGS & PLACE IN
CLOSED METAL CONT FOR DISPOSAL. LARGE-EVACUATE AREA. WEAR
BU/MINES/NIOSH APPR RESPIRATOR. DIKE & ABSORB W/DRY
SAND,EARTH.REMOVE CONAMINATED CLOTHING IMMED. WAS H AFFECTED AREAS
WITH SOAP & WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID DIRECT CONTACT OR INHALATION OF
VAPORS
Other Precautions:NOTE TO PHYSICIAN: OVER EXPOSURE TO MANY CHLORINATED
SOLVENTS,ESP IF ACCOMPANIED BY ANOXIA,MAY CAUSE TEMP CARDIAC
IRRITABILITY. MAINTAIN ADEQUATE OXYGENATION. AVOID SYMPATOMIMETIC
AMINES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:BU/MINES/NIOSH APPROVED RESPIRATOR FOR VAPOR
Ventilation:MECHANICAL TO PROVIDE CLEAN AIR AT POINT OF OPERATIONS.
Other Protective Equipment:IMPERVIOUS APRON EYE-WASH FOUNT, EMERGENCY
SHOWER
Supplemental Safety and Health
O-T-236, GRADE B. PRODUCT CODE NR 80-0144
================== Physical/Chemical Properties ==================
HCC:T4
Boiling Pt:B.P. Text:250F/121C
Vapor Pres:13
Vapor Density:5.76
Spec Gravity:1.619
Evaporation Rate & Reference:>1/BUTYL ACETATE/
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR COLORLESS LIQUID. CHLOROFORM-TYPE ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES LIKE SODIUM HYDROXIDE
Stability Condition to Avoid:EXCESSIVE TEMP & OPEN FLAME
Hazardous Decomposition Products:HCL, CHLORINE, PHOSGENE
==================== Disposal Considerations ====================
Waste Disposal Methods:SPREAD SPILL WITH ABSORBENT IN AN OPEN AREA &
LET EVAPORATE OR LANDFILL CLOSED CONTAINERS IAW LOCAL,STATE & FED
REGS. REFER ALSO TO MCA/SD-24.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:164 0184 55 DEVELOPER
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 85-90%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM SULFITE
CAS:7757-83-7
RTECS #:WE2150000
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:HYDROQUINONE (SARA III)
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: <4%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9394
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: <2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:POTASSIUM CARBONATE
CAS:584-08-7
RTECS #:TS7750000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 ORAL (RAT): NOT GIVEN
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. EYES: CAUSES IRRITATION. SKIN: CAUSES
IRRITATION. MAY CAUSE ALLERGIC SKIN REACTION. INGESTION: MAY BE
HARMFUL IF SWALLOWED.
Explanation of Carcinogenicity:PER MSDS:CARC CLASS PER
IARC/ACGIH/NTP/OSHA: NONE;MATL KNOWN TO STATE OF CA TO CAUSE
CANCER/ADVERSE REPRO EFFECT:NONE.
Effects of Overexposure:EYES & SKIN IRRITATION. ALLERGIC SKIN REACTION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:IF SYMPTOMATIC MOVE TO FRESH AIR. GET MED ATTN IF
SYMPTOMS PERSIST. EYES:IMMED FLUSH W/PLENTY OF WATER FOR @ LEAST
15MINS. GET MED ATTN. SKIN:IMMED REMOVE CONTAMINATED
CLOTHING/SHOES. WASH AREA W/SOAP & PLENTY OF WATER. GET MED
ATTN.INGEST:INDUCE VOMITING AS DIRECTED BY MED PERSONNEL. NEVER
GIVE ANYTHING BY MOUTH TO UNCONSC PERSON. CALL DR/POISON CONTROL
CNTR IMMED.
===================== Fire Fighting Measures =====================
Flash Point:NON-COMBUSTIBLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER W/LG AMTS OF WATER. CLEAN
SURFACE THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. KEEP AWAY FROM
INCOMPATIBLE SUBSTANCES. USE W/ADEQUATE VENTILATION. AVOID CONTACT
W/ EYES/ SKIN/CLOTHING.
Other Precautions:THE ROUTINE USE OF A NONALKALINE (ACID) TYPE OF HAND
CLEANER AND REGULAR CLEANING OF WORKING SURFACES WILL HELP MINIMIZE
THE POSSIBILITY OF A SKIN REACTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED. IF ENGINEERING CONTROLS
DO NOT MAINTAIN AIRBORNE CONCENTRATIONS BELOW RECOMMENDED EXPOSURE
LIMITS, AN APPROVED RESPIRATOR MUST BE WORN. RESPIRATOR TYPE: DUST.
IF RESPIRATORS AREUSED, A PROGRAM SHOULD BE INSTITUTED.
Ventilation:GOOD GEN VENTILATION (TYPICALLY 10 AIR CHANGES/HR) SHOULD
BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
READY-TO-USE, 2 1/2 GALS.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Decomp Temp:Decomp Text:NOT GIVEN
Vapor Pres:18MM
Vapor Density:0.6
Spec Gravity:1.10
pH:10.4
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE.
Appearance and Odor:LIQUID, TAN COLOR, ODORLESS.
Percent Volatiles by Volume:85
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OXIDES OF SULFUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CERIATED TUNGSTEN, TT-C532G-7
Preparer's Name:DENNIS WILSON
CAGE:FO606
CAGE:98251
CAGE:FO606
============= Composition/Information on Ingredients =============
Ingred Name:TUNGSTEN
CAS:7440-33-7
RTECS #:YO7175000
Fraction by Wt: 98%
OSHA PEL:N/K
ACGIH TLV:1 MG/M3;3 STEL
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION OF FUMES GENERATED DURING
WELDING. MOST STUDIES FOUND TUNGSTEN TO BE TOXICOLOGICALLY INERT.
SIGNS AND SYMPTOMS OF EXPOSURE: BREATHING DIFFICULTY, HEADACHE,
NAUSEA, DRYNESS OR IRRITATION OF NOSE, THROAT, EYES. BURNING
SENSATION OF SKIN OR EYES. UNCONSCIOUSNESS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:RESPIRATORY PROBLEMS, ERYTHMAS.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . EYES:IMMEDIATELY FLUSH W/POTABLE
WATER FOR A MINIMUM OF 15 MINUTES, SEEK ASSISTANCE FROM MD .
INHAL:REMOVE TO FRESH AIR. IF BREATHING IMPAIRED, ASSISTED RESPIR
ATION MAY BE REQUIRED. SKIN:TREAT U.V. EXPOSURE SIMILAR TO SEVERE
SUNBURN, SEEK MEDICAL ATTENTION!
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE . NOT
FLAMMABLE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:WELDING ARC & SPARKS CAN IGNITE
COMBUSTIBLE MATLS. REFER TO ANSI Z49.1, "SAFETY IN WELDING &
CUTTING", PUBLISHED BY THE AMERICAN WELDING SOCIETY.
================== Accidental Release Measures ==================
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH APPROVED RESPIRABLE FUME RESPIRATOR
WHEN WELDING IN CONFINED SPACES & WHENEVER FUME CONCENTRATIONS
EXCEED APPLICABLE LIMITS FOR TUNGSTEN OR OTHER WELDING FUMES. ALL
REQUIREMENTS SET FORTH IN 29 CFR 1910.134 SHOULD BE MET.
Ventilation:GEN &/OR LOC EXHST AT WELDING ARC REC. IS SUCH EQUIP IS NOT
AVAIL, USE NIOSH APPRVD RESP AS SPECIFIED. AIR (SUPP DATA)
Other Protective Equipment:ANSI APPRVD EYE WASH FOUNTAIN & DELUGE
SHOWER . FOOTWEAR:SUITABLE FOR METAL WORKING. CLOTHING: DARK, (SUPP
DATA)
Work Hygienic Practices:OPERATOR TRAINED TO AVOID ELECTRICAL SHOCK & UV
RAY EXPOSURE.
Supplemental Safety and Health
BP:10220F,5660C. HAZ DECOMP PROD:DEPENDING ON PROCESS, PROC & METAL
WELDED. SOME LOSS OF ELECTRODE WILL OCCUR. VENT:SAMPLING IF NEC TO
DETERMINE CORRECTIVE MEASURES. EYE PROT:FULL LGTH FSHLD OR
WELDER'S HELMET W/PROPER FILTER LENS. OTHER PROT
EQUIP:SUBSTANTIAL-APRONS, ETC. AS REC BY ANSI Z49.1.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:SUPP DATA
Spec Gravity:19
Solubility in Water:NOT SOLUBLE
Appearance and Odor:SOLID, GRAY METAL CYLINDER; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Hazardous Decomposition Products:WELDING FUMES (OXIDES OF METAL BEING
WELDED & GASES, SUCH AS CARBON MONOXIDE, OZONE & OXIDES OF
NITROGEN) (SUPP DATA)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:B30W205 PROMAR 200 FLAT NAVAJO WHITE
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL, GLYCOL *96-3*
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: <2%
Other REC Limits:10 MG/CUM
OSHA PEL:50 PPM
ACGIH TLV:C 127 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CRYSTALLINE-QUARTZ SILICA, SILICA DUST (SUSPECTED HUMAN
CARCINOGEN BY IARC-GROUP 2A; SUSPECTED CARCINOGEN NTP) *96-3*
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 2-16%
Other REC Limits:0.05 MG/CUM (NIOSH)
OSHA PEL:10 MG/CUM %RESP SIO2
ACGIH TLV:0.1 MG/CUM RESP DUST
Ingred Name:CLAY (KAOLIN), ALUMINUM SILICATE *96-3*
CAS:1332-58-7
RTECS #:GF1670500
Fraction by Wt: 5-12%
ACGIH TLV:10 MG/CUM TOTAL DUST
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 0-5%
OSHA PEL:2 MG/CUM (RESP DUST)
ACGIH TLV:2 MG/CUM (RESP DUST)
Ingred Name:SILICA, MICA, MUSCOVITE
CAS:12001-26-2
RTECS #:VV8760000
Fraction by Wt: 0-3%
ACGIH TLV:3 MG/CUM
Ingred Name:CARBONIC ACID, CALCIUM SALT (1:1), CALCIUM CARBONATE,
DURAMITE
CAS:471-34-1
RTECS #:FF9335000
Fraction by Wt: 0-15%
Other REC Limits:10 MG/CUM (DUST)
Ingred Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
CARCINOGEN, IARC GROUP 3)*96-3*
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 9-15%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 40.3-55%
Ingred Name:VOLATILE ORGANIC CONTENT: 0.16-0.23 LBS/GAL; 0.4-0.73
LBS/GAL LESS WATER
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:IRRITATION TO EYES, SKIN & UPPER
RESPIRATORY SYSTEM. LONG TERM EXPOSURE TO HIGH LEVELS OF SILICA
DUST MAY CAUSE SILICOSIS & POSSIBLY CANCER. PROLONGED OVEREXPOSURE
TO SOLVENTS MAY CAUSE ADVERSE EFFECT S TO THE LIVER & URINARY
SYSTEMS.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:IRRITATION, HEADACHE, NAUSEA, DIZZINESS,
REDNESS, ITCHING, BURNING SENSATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. KEEP WARM
& QUIET. SKIN: WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH W/WATER
FOR 15 MINS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, DRY CHEMICAL, ALCOHOL FOAM.
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT W/SCBA. WATER
SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE. USE WATER TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE DUE TO
BUILD UP OF PRESSURE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES. VENTILATE & REMOVE
W/INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
TRANSFER ONLY TO APPROVED CONTAINERS W/COMPLETE & APPROPRIATE
LABELING. DON'T TAKE INTERNALLY.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID BREATHING
VAPORS/SPRAY MIST. AVOID CONTACT W/SKIN & EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A PROPERLY FITTED ORGANIC VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA. WHEN SANDING/ABRADING THE DRIED
FILM, WEAR A DUST/MIST RESPIRATOR APPROVED BY NIOSH/MSHA.
Ventilation:LOCAL/GENERAL EXHAUST VENTILATION
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
PH: 8.2-9.8
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212-486F
Vapor Density:>1
Spec Gravity:1.12-1.55
pH:(SUPP)
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NAVAJO WHITE
Percent Volatiles by Volume:57-81
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:BY FIRE: CO, CO2.
==================== Disposal Considerations ====================
Waste Disposal Methods:NON-HAZARDOUS. INCINERATE IN APPROVED FACILITY.
DON'T INCINERATE CLOSED CONTAINERS. DISPOSE OF IAW/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:147 5979,LINAGRAPH 1000 LIQ STABILIZER
Kit Part:Y
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER (70-75%)
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 72.5%
Ingred Name:SODIUM THIOSULFATE (20-25%)
CAS:7772-98-7
RTECS #:XN6476000
Fraction by Wt: 22.5%
Ingred Name:POTASSIUM SULFITE (1-5%)
CAS:10117-38-1
RTECS #:WT3530000
Fraction by Wt: 03.0%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE EYE/SKIN IRRITATION.
Effects of Overexposure:NONE NOTED BY MFG:LOW TOXICITY & LOW HAZARD TO
HEALTH.USE STD LOW TOXICITY CHEMICAL FIRST AID.
======================= First Aid Measures =======================
First Aid:INHALE:REMOVE TO FRESH AIR,GIVE CPR/O*2 IF NEED;EYES:FLUSH W
LG AMTS H*2O FOR 15 MIN;SKIN;FLUSH W LG AMTS H*2O;INGEST:RINSE
MOUTH, CALL PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NON FLAMMABLE:USE MEDIA SUITABLE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:WEAR SELF-CNTND BRTHG APP;H*2O SPRAY COOL
CONT.
Unusual Fire/Explosion Hazard:CONTAINERS MAY EXPLODE IN HEAT OF FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE UNPROTECTED PERSONS.STOP LEAK.H*2O
SPRAY CONTAINERS. ABSORB WITH COMMERCIAL ABSORBENT,SHOVEL INTO
WASTE DISPOSAL CONTAINERS;LG SPILL:DIKE WITH COMMERCIAL
ABSORBENT,TRANSFER INTO WASTE DISPOSA L CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED,LOW
FIRE RISK AREA.PROTECT FROM PHYSICAL DAMAGE.AVOID UNNECESSARY
PHYSICAL CONTACT.KEEP CONTAINERS TIGHTLY CLOSED
Other Precautions:MAINTAIN STANDARD HYGIENE(REMOVE & WASH CONTAMINATED
CLOTHIN)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL REQUIREMENTS.
Ventilation:NO SPECIAL REQUIREMENTS.
Other Protective Equipment:NO SPECIAL REQUIREMENTS.
Supplemental Safety and Health
PROCESSING KIT HAS 4 PARTS WHICH INCLUDE:STOP BATH PART A & PART
B,STABILIZER & DEVELOPER;KEY1:N1;THIS ENTRY DESCRIBES:LINAGRAPH
1000 LIQUID STABILIZER;EFFECTIVE 80061 (2MAR80),NSN REPLACES
6750-01-02 4-9257;SOLUTION #2989.
================== Physical/Chemical Properties ==================
HCC:B1
Boiling Pt:>100.C, 212.F
Vapor Pres:17
Vapor Density:0.60
Spec Gravity:1.25
pH:8.0
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS, ODORLESS LIQ
Percent Volatiles by Volume:75%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MINERAL ACIDS
Stability Condition to Avoid:NONE NOTED.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED CONTAINERS.PENDING
DISPOSAL.HANDLE & DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE,& LOCAL REGULATIONS.MFG SUGGESTS
FLUSHING DOWN SEWER WITH EXCESS WATER.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:PRIMER 3203 U-SEAL
CAGE:0KM49
CAGE:0KM49
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TRIETHYLENETETRAMINE; (TRIETHYLENE TETRAMINE)
CAS:112-24-3
RTECS #:YE6650000
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:UNKNOWN. CHRONIC:PROLONGED
EXPOSURE MAY RESULT IN CENTRAL NERVOUS SYSTEM DEPRESSION.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:OVEREXPOSURE CAUSES NOSE & THROAT IRRITATION,
HEADACHE, NAUSEA & LOSS OF CONSCIOUSNESS.
Medical Cond Aggravated by Exposure:UNKNOWN.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. ADMINISTER OXYGEN IF NECESSARY.
EYES:FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINUTES. CALL MD.
SKIN:WASH W/SOAP & WATER. INGEST:IMMEDIATELY CALL MD.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:20.0F,-6.7C
Lower Limits:1.4%
Upper Limits:11.5%
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . REMOVE ALL SOURCES OF IGNITION. SPRAY WATER
TO COOL NEARBY CONTAINERS.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE ALL SOURCES OF
IGNITION. BROADCAST ABSORBENTS & SCOOP INTO CONTAINER, THEN SEAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM SOURCES OF IGNITION.
PREVENT LIQUIDS FROM ENTERING SEWERS.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED VAPOR CANISTER.
Ventilation:LOCAL EXHAUST RECOMMENDED. MECHANICAL EXPLOSION PROOF
EQUIPMENT.
Other Protective Equipment:LONG LEG, LONG SLEEVE CLOTHING.
Work Hygienic Practices:WASH HANDS BEFORE HANDLING FOOD.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:175F,79C
Vapor Pres:190 @ 100F
Vapor Density:2.5
Spec Gravity:A-0.93/B-0.81
Solubility in Water:16% BY WEIGHT.
Appearance and Odor:STRAW LIQUID, STRONG ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, CAUSTICS, AMINES, AMMONIA.
Stability Condition to Avoid:HIGH HEAT, FLAMES.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE MATERIAL I/A/W LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:QUICK-FIX #FQFI0632
Preparer's Name:TIMOTHY J.COLLITONS
CAGE:DO235
CAGE:DO235
CAGE:19110
============= Composition/Information on Ingredients =============
Ingred Name:ACETIC ACID (SARA III)
CAS:64-19-7
RTECS #:AF1225000
Fraction by Wt: 1.0%
OSHA PEL:10 PPM
ACGIH TLV:10 PPM/15 STEL; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SODIUM METABISULFITE
CAS:7681-57-4
RTECS #:UX8225000
Fraction by Wt: 5.0%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3; 9192
Ingred Name:AMMONIUM THIOSULFATE
CAS:7783-18-8
RTECS #:XN6465000
Fraction by Wt: 80.0%
Ingred Name:BORIC ACID
CAS:10043-35-3
RTECS #:ED4550000
Fraction by Wt: 1.0%
Ingred Name:UNIDENTIFIED COMPONENTS (NON HAZARDOUS)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:ACUTE:EYES,SKIN AND RESPIRATORY
IRRITATION. CHRONIC:DERMATITIS.
Effects of Overexposure:RESPIRATORY,EYE AND SKIN IRRITATION PROLONGED
SKIN CONTACT MAY CAUSE DERMATITIS.
Medical Cond Aggravated by Exposure:NOT KNOWN
======================= First Aid Measures =======================
First Aid:EYES:FLUSH EYES WITH PLENTY OF WATER FOR 15 MINUTES,CALL
MEDICAL HELP SKIN:WASH THOROUGHLY WITH SOAP & WATER.
INHALATION:REMOVE TO FRESH AIR CALL A DOCTOR FOR ADVICE.
INGESTION:CONTACT POISION CONTROL CENTER OR PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING MATERIALS/FIRES
Fire Fighting Procedures:NO SPECIAL PROCEDURES REQUIRED
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION:USE SUITABL
ABSORBENT MATERIAL AND RECOVER FOR PROPER DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY AND WELL VENTILATED
AREA;STORE IN CLOSED CONTAINER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC
VAPORS/MIST IF ABOVE TLV/PEL
Ventilation:LOCAL EXHAUST TO KEEP CONDITION UNDER CONTROL
Work Hygienic Practices:AVOID CONTACT WITH EYES AND SKIN: DO NOT
BREATHE VAPORS/MIST WASH THOROUGHLY AFTER EACH USE.
Supplemental Safety and Health
MSDS RECEIVED BY DGSC:DEC 22,1987
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>212/100C
Vapor Pres:<20 MMHG
Vapor Density:<1.0
Spec Gravity:1.34
Evaporation Rate & Reference:<1.0 (BUAC=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR,COLORLESS LIQUID;SLIGHT VINEGAR ODOR
Percent Volatiles by Volume:40.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG MINERAL ACIDS,STRONG OXIDIZERS
Stability Condition to Avoid:EXTREME HEAT
Hazardous Decomposition Products:AMMONIA,SULFUR DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF COLLECTED MATERIAL IN ACCORDANCE WITH
LOCAL,STATE AND FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:METCO 72F-NS
Resp. Party Other MSDS Num.:50-329
CAGE:01FK3
CAGE:01FK3
============= Composition/Information on Ingredients =============
Ingred Name:TUNGSTEN CARBIDE
CAS:12070-12-1
RTECS #:YO7250000
= Wt:87.
Ingred Name:COBALT
CAS:7440-48-4
RTECS #:GF8750000
= Wt:12.
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.02 MG/M3
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
= Wt:1.
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE PROVIDED BY MFR.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: RESPIRATORY SYSTEM,
SKIN, EYES, & GASTROINTESTINAL TRACT. INHALATION: MAY CAUSE LUNG
DAMAGE & RESPIRATORY SYSTEM IRRITATION. MAY CAUSE PROGRESSIVE,
DIFFUSE PNEUMONIA, RESPIRATORY SENSI TIZATION. MAY CAUSE SIDEROSIS
(BENIGN PNEUMOCONIOSIS). INGESTION: MAY CAUSE IRRITATION TO THE
RESPIRATORY SYSTEM & GASTROINTESTINAL TRACT. SKIN: MAY CAUSE
ALLERGIC DERMATITIS OR ECZEMA. EYES: MAY C AUSE IRRITATION.
Explanation of Carcinogenicity:NONE PROVIDED BY MFR.
Effects of Overexposure:EYE: POSSIBLE IRRITATION. SKIN: POSSIBLE
IRRITATION, DERMATITIS, ECZEMA. INHALATION: POSSIBLE IRRITATION TO
THE RESPIRATORY SYSTEM, RESPIRATORY SENSITIZATION CHARACTERIZED BY
COUGH, WHEEZING & SHORTNE SS OF BREATH. INGESTION: POSSIBLE
IRRITATION TO THE RESPIRATORY SYSTEM & GASTROINTESTINAL TRACT.
Medical Cond Aggravated by Exposure:CONSULT A PHYSICIAN
======================= First Aid Measures =======================
First Aid:EYE: FLUSH EYE WITH WATER FOR AT LEAST 15 TO 20 MINS WHILE
HOLDING EYELID OPEN. IF IRRITATION PERSISTS, CONSULT A PHYSICIAN.
SKIN: WASH WITH SOAP & WATER. IF IRRITATION PERSISTS, CONSULT A
PHYSICIAN.INHALATION: EXPOSE TO FRESH AIR. CONSULT A PHYSICIAN IF
IRRITATION OR RESPIRATORY DISTRESS PERSISTS. INGESTION: CONSULT A
PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE CLASS D FIRE EXTINUGISHER
Fire Fighting Procedures:TREAT AS A METALLIC FIRE. USE NIOSH/MSHA
APPROVED SELF CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE
CLOTHING IF INVOLVED IN A FIRE.
Unusual Fire/Explosion Hazard:FINE METAL DUSTS ARE FLAMMABLE & MAY
EXPLODE WHEN EXPOSED TO HEAT, FLAME OR STRONG OXIDIZERS. TUNGSTEN
CARBIDE OXIDIZES ON HEATING IN AIR; BURNS IN FLUORINE AT ROOM
TEMPERATURE. COBALT MAY IGNITE IF A IRBORNE IN THE PRESENCE OF AN
IGNITION SOURCE OR SPONTANEOUSLY. IRON MAY IGNITE IN THE PRESENCE
OF AN IGNITION SOURCE.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM LOOSE POWDER ONLY WITH VACUUMS EQUIPPED
WITH HEPA FILTERATION. VACUUMS APPROPRIATE FOR USE WITH METALLIC
DUSTS SHOULD BE UTILIZED. WIPE THE AREA CLEAN. DO NOT USE WATER FOR
CLEAN UP OPERATIONS. DO NOT SWEEP. AVOID GENERATING AIRBORNE DUST.
Neutralizing Agent:NONE PROVIDED BY MFR.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM INCOMPATABLES. STORE
PRODUCT CONTAINERS IN A WELL-VENTILATED, CLEAN, COOL & DRY AREA.
STORE IN A MANNER TO MINIMIZE PUNCTURES & BREAKAGE OF CONTAINERS.
Other Precautions:AVOID INGESTION, INHALATION & EXCESSIVE SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH-APPROVED REPIRATOR WITH FILTER CARTRIDGES
APPROVED FOR DUST/FUMES/MISTS SHOULD BE WORN AT ALL TIMES DURING
THE THERMAL SPRAY PROCESS TO PROTECT THE OPERATOR FROM EXPOSURE TO
DUST & FUMES. RESPIR ATORS MAY ALSO BE WORN WHEN PRODUCT HANDLING
GENERATES DUST.
Ventilation:PRODUCT SHOULD BE USED WITH THE APPROPRIATE LOCAL EXHAUST
VENTILATION PROVIDED.
APPROPRIATE AS NEEDED.
Other Protective Equipment:EAR PROTECTION AS APPROPRIATE. AN ALUMINIZED
APRON IS TO BE WORN DURING THE PLASMA SPRAY PROCESS. OTHER
APPROPRIATE PROTECTIVE CLOTHING MAY BE WORN AS NECESSARY DURING
PRODUCT HANDLING TO AVOID CONTACT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:2200 TO 2300 DEG F
Decomp Temp:Decomp Text:NONE PROVIDED BY MFR.
Spec Gravity:4.5 TO 6.3 (H20=1)
Viscosity:NONE PROVIDED BY MFR.
Solubility in Water:INSOLUBLE
Appearance and Odor:POWDER, NO ODOR
Percent Volatiles by Volume:NONE PROVIDE
Corrosion Rate:NONE PROVIDED BY MFR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
TUNGSTEN CARBIDE IS INCOMPATABLE WITH FLUORINE, CHLORINE, TRIFLUORIDE,
OXIDES OF NITROGEN & LEAD DIOXIDE. COBALT IS INCOMPATIBLE WITH
STRONG OXIDIZERS & AMMONIUM NITRATE.
Stability Condition to Avoid:NONE PROVIDED BY MFR.
Hazardous Decomposition Products:OZONE & NITRIC OXIDE ARE FORMED BY THE
PLASMA FLAME (SIMILAR TO WELDING FUMES). THIS ACTION IS INDEPENDENT
OF METAL POWDER.
Conditions to Avoid Polymerization:WILL NOT OCCUR
===================== Ecological Information =====================
Ecological:NOT PROVIDED
==================== Disposal Considerations ====================
Waste Disposal Methods:EMPTY PRODUCT CONTAINERS, PRODUCT WASTE &
CLEANING MEDIA SHOULD BE STORED & DISPOSED OF ACCORDING TO THE
APPROPRIATE LOCAL, STATE & FEDERAL REGULATORY GUIDELINES.
=================== MSDS Transport Information ===================
Transport Information:SEE TRANSPORTATION DATA.
===================== Regulatory Information =====================
SARA Title III Information:SULFURIC ACID IS EHS WITH RQ = 1000 LB. LEAD
IS 313 CHEMICAL
Federal Regulatory Information:SULFURIC ACID CERCLA RQ = 1000 LB. LEAD
CERCLA RQ = 10 LB
State Regulatory Information:NOT PROVIDED
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:BELZONA M.P. HI BUILD ELASTOMER SOLIDFIER
CAGE:BELZO
CAGE:67020
CAGE:BELZO
============= Composition/Information on Ingredients =============
Ingred Name:DIETHYLTOLUENEDIAMINE
CAS:68479-98-1
Ingred Name:MERCURY, (NEODECANOATO-O) PHENYL
CAS:26545-49-3
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:YES
Health Hazards Acute and Chronic:INGESTION: TOXIC. EYE/SKIN: CORROSIVE,
MODERATELY IRRITATING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INGESTION: TOXIC. SKIN/EYES: MODERATELY
IRRITATING, & CORROSIVE.
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE TO FRESH AIR & GIVE ARTIFICIAL RESPIRATION
IF NECESSARY. EYES: FLUSH W/WATER FOR 15 MINS. WASH W/DILUTED BORIC
ACID (1%). SKIN: WASH W/SOAP & WATER. INGESTION: DON'T INDUCE
VOMITING. RINSE MOUTH W/WATER. DRINK LARGE QUANTITIES OF WATER.
INGESTION: CALL PHYSICIAN IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:250F
Extinguishing Media:WATER FOG (NOT A DIRECT STREAM OF WATER), FOAM,
CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING, FULL BUNKER GEAR
SHOULD BE WORN IN EXTREME CASES. USE SAND TO CONTAIN BURNING
MATERIAL. RUN OFF FROM FIRE MAY CAUSE POLLUTION.
Unusual Fire/Explosion Hazard:DECOMPOSITION & COMBUSTION PRODUCTS MAY
BE HAZARDOUS. EMPTY CONTAINERS RETAIN RESIDUE & MAY BE DANGEROUS.
OVERHEATING MAY CAUSE CONTAINER TO RUPTURE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. USE SAND TO
ABSORB SPILLED MATERIAL & DISPOSE OF PROPERLY. KEEP OUT OF WATER
SUPPLY.
======================Handling and Storage ======================
Handling and Storage Precautions:OVERHEATING MAY CAUSE CONTAINER TO
RUPTURE. MUST BE KEPT IN DRY, COOL & COVERED AREA. CHECK ALL
CONTAINERS FOR LEAKS.
Other Precautions:AVOID BREATHING VAPORS, CONTACT W/SKIN. EMPTY
CONTAINERS RETAIN RESIDUE & MAY BE DANGEROUS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR SUITABLE FOR
ORGANIC VAPORS IF NECESSARY.
Ventilation:PROVIDE ADEQUATE CROSS AIR CIRCULATIONS. EXHAUST AT POINT
OF USE.
Other Protective Equipment:EYEWASH STATION, EMERGENCY SHOWER,
IMPERMEABLE APRON OR GARMENT.
Work Hygienic Practices:DISCARD CONTAMINATED SHOES. REMOVE CONTAMINATED
CLOTHING.
Supplemental Safety and Health
WT/GAL: 12.81 LBS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F
Vapor Pres:0.01
Vapor Density:>AIR
Spec Gravity:1.54
Solubility in Water:1.0-10.0%
Appearance and Odor:CREAM PASTE W/SLIGHT AMINE ODOR.
Percent Volatiles by Volume:0%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, AMINES, STRONG ACIDS
Stability Condition to Avoid:SOURCES OF IGNITION
Hazardous Decomposition Products:CO, CO2, OXIDES OF NITROGEN & MERCURY
VAPORS
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL IN ACCORDANCE W/LOCAL, STATE, & FEDERAL
REGULATIONS. SOLIDIFY & DISPOSE OF PROPERLY. CONTACT SAFETY
ENGINEER FOR INSTRUCTIONS & APPROVAL. COMBUSTIBLE LIQUID. CLASS
IIIB.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:AUDRUCIL INJECTION
CAGE:58750
CAGE:58750
============= Composition/Information on Ingredients =============
Ingred Name:FLUOROURACIL (SARA III)
CAS:51-21-8
RTECS #:YR0350000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 95%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:DATA PER MGF MSDS.
Effects of Overexposure:SEE HEALTH HAZARDS DATA.
======================= First Aid Measures =======================
First Aid:EYES:IRRIGATE IMMEDIATELY WITH WATER OR SALINE.RINSE WITH
COPIOUS AMOUNTS OF WATER.SKIN:WASH WITH SOAP &
WATER.INHALATION/INGESTION:SEEK MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:TOXIC FUMES
================== Accidental Release Measures ==================
Spill Release Procedures:DEACTIVATE WITH DILUTE BLEACH SOLUTION. RINSE
WELL WITH WATER.
Neutralizing Agent:DILUTE BLEACH
======================Handling and Storage ======================
Handling and Storage Precautions:ADRUCIL IS A POTENT ANTI-CANCER
DRUG.STORE BETWEEN 15-30C.PROTECT FROM LIGHT.
Other Precautions:IF ADRUCIL SOLUTION CONTACTS SKIN,IMMEDIATELY WASH
THOROUGHLY WITH SOAP AND WATER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR FOR TOXIC MISTS OR
AEROSOLS.
Ventilation:LOCAL EXHAUST:ADEQUATE/VERTICAL LAMINAR FLOW
HOOD.MECHANICAL(GENERAL): SAME.
Other Protective Equipment:LONG SLEEVED IMPERMEABLE, DISPOSABLE GOWN
WITH ELASTIC CUFFS.
Work Hygienic Practices:CAUTION IN THE HANDLING AND USE MUST BE
EXERCISED.
Supplemental Safety and Health
MSDS UNDATED
================== Physical/Chemical Properties ==================
HCC:K2
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:1.0297
pH:9.0
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR TO FAINTLY YELLOW AQUEOUS YELLOW SOLUTION; NO
ODOR
Percent Volatiles by Volume:95
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:FLUORINE AND NXO GASES
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES;DISPOSAL MUST BE IN
ACCORDANCE WITH LOCAL,STATE AND FEDERAL REGULATIONS
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:VELCRO BRAND LOOP 0199
CAGE:11153
CAGE:11153
============= Composition/Information on Ingredients =============
Ingred Name:PAINTS,PRESERVATIVES & SOLVENTS (CONSISTING OF INGREDIENTS
2-7)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PIGMENTS
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CATALYST
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VEHICLE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SOLVENTS
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ADDITIVES
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:OTHERS
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ALLOYS AND METALLIC COATINGS (CONSISTING OF INGREDIENTS
9-13)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BASE METAL
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ALLOYS
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:METALLIC COATINGS
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:FILLER METAL; (FILLER METAL PLUS COATING OR CORE FLUX)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:OTHERS
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:HAZARDOUS MIXTURES OF OTHER LIQUIDS, SOLIDS OR GASES
(CONSISTING OF INGREDIENT 15)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:FORMALDEHYDE (SARA 302/313) (CERCLA)
CAS:50-00-0
RTECS #:LP8925000
OSHA PEL:SEE 1910.1048
ACGIH TLV:C 0.3 PPM, A2
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:HAS NOT BEEN ESTABLISHED AT THIS TIME.
THIS FABRIC CAN RELEASE SMALL AMOUNTS OF FORMALDEHYDE. EXPOSURE TO
FORMALDEHYDE MAY RESULT FROM SKIN CONTACT WITH FABRIC OR BY
INHALATION OF FORMALDEHYDE VAPOR R ELEASED INTO THE AIR.
OVEREXPOSURE TO FORMALDEHYDE FROM ANY SOURCE MAY CAUSE SKIN OR EYE
IRRITATION (EFTS OF OVEREXP)
Explanation of Carcinogenicity:FORMALDEHYDE:IARC MONOGRPAHS, SUPP, VOL
7, PG 211, 1987:GROUP 2A. NTP 7TH ANNUAL RPT ON CARCINS, 1994:ANTIC
TO ((SUPDAT)
Effects of Overexposure:HLTH HAZS:AFTER PROLONGED CONTACT AND
FORMALDEHYDE VAPOR OVEREXPOSURE MAY CAUSE EYE AND RESPIRATORY TRACT
IRRITATION. IN THE EVENT OF OVEREXPOSURE, REMOVE THE INDIVIDUAL
FROM CONTACT WITH THE SOURCE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . IF SWALLOWED, FOLLOW ESTABLISHED
FIRST AID PROCEDURES FOR INGESTION OF A FOREIGN OBJECT.
INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP) .
EY ES:IMMEDIATELY FLUSH W/POTABLE WATER FOR A MINIMUM OF 15
MINUTES, SEEK ASSISTANCE FROM MD . SKIN:FLUSH W/COPIOUS AMOUNTS OF
WATER. CALL MD .
===================== Fire Fighting Measures =====================
Extinguishing Media:USE CLASS A OR B EXTINGUISHER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:NO SPECIAL PROCEDURES REQUIRED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL HANDLING OR STORAGE
REQUIRED.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NONE REQUIRED.
Ventilation:NOT REQUIRED.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLAN OF CARCIN:BE CARCINOGEN. ANIMAL:NASAL TUMORS.
================== Physical/Chemical Properties ==================
Spec Gravity:>1.0
Solubility in Water:INSOLUBLE
Appearance and Odor:TEXTILE FASTENER-NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
OXIDES OF NITROGEN AND OTHER NOXIOUS FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE ACCORDING TO LOCAL, STATE AND FEDERAL
GUIDELINES.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:816 MEDIUM BLUE
CAGE:0A3L4
CAGE:0A3L4
============= Composition/Information on Ingredients =============
Ingred Name:AMORPHOUS SILICA GEL; (AMORPHOUS PRECIPITATED SILICA)
CAS:112926-00-8
Fraction by Wt: 5%
OSHA PEL:N/K
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:SUPP DATA:MAY TRAVEL A LONG DISTANCE TO A SOURCE OF
IGNITION & FLASH BACK.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP:BE FATAL. CHRONIC:LAB ANIMAL EFTS:KIDNEY
DMG, EYE DMG, LUNG DMG, LIVER DMG, SPLEEN DMG, ANEMIA, (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:BRAIN DMG. HUMAN EFTS:LIVER DMG, CARD ABNORMS. RPTS
HAVE ASSOC RPTD & PRLNG OVEREXP TO SOLVS W/PERM BRAIN(ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19:& NERV SYS DMG. ING 2:RPTD BRTHG/SKIN CONT MAY INCR
POTENCY OF NEUROTOXINS, SUCH AS HEXANE, WHEN EXPOS (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20:OCCUR AT SAME TIME. ING 3:HAS BEEN SHOWN TO CAUSE
CANCER IN LAB ANIMALS (MFR). ING 4:LAB ANIMALS:MAY BE (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21:HARMFUL TO FETUS. RPTD EXPOS HAS BEEN ASSOC W/HIGH
FREQUENCY HEARING LOSS; HUMAN CONSEQUENCES UNCERTAIN. (ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22:WARNING! PROD CNTNS CHEM(S) KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE BIRTH DEFECTS/OTHER REPRO HARM. (ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23:NOTE:TOLUENE APPEARS ON NAVY LIST OF OCCUP CHEM
REPRO HAZS. SEEK CONSULTATION FROM APPROP HLTH (ING 25)
RTECS #:9999999ZZ
Ingred Name:ING 24:PROFESSIONALS CONCERNING LATEST HAZARD LIST INFO &
SAFE HANDLING & EXPOSURE INFO .
RTECS #:9999999ZZ
Ingred Name:PIGMENTS; (ORGANIC & INORGANIC PIGMENTS)
Fraction by Wt: 19%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACETONE (SARA 313) (CERCLA)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 36%
OSHA PEL:1000 PPM
ACGIH TLV:750 PPM;1000 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE) (MEK) (SARA 313) (CERCLA)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 6%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM;300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PHTHALIC ACID, BENZYL BUTYL ESTER (SARA 313) (CERCLA)
CAS:85-68-7
RTECS #:TH9990000
Fraction by Wt: 2%
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:TOLUENE (SARA 313) (CERCLA)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 13%
OSHA PEL:200 PPM
ACGIH TLV:50 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ALUMINUM; (ALUMINUM FLAKE)(SARA 313)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 2%
OSHA PEL:15 MG/M3 DUST
ACGIH TLV:10 MG/M3 DUST
Ingred Name:STODDARD SOLVENT; (MINERAL SPIRITS)
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 2%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:TRIMETHYL BENZENE; (TRIMETHYL BENZENE (MIXED ISOMERS))
CAS:25551-13-7
RTECS #:DC3220000
Fraction by Wt: 2%
OSHA PEL:25 PPM
ACGIH TLV:25 PPM
Ingred Name:1,2,4-TRIMETHYLBENZENE (SARA 313)
CAS:95-63-6
RTECS #:DC3325000
Fraction by Wt: 4%
OSHA PEL:25 PPM
ACGIH TLV:25 PPM
Ingred Name:XYLENE (SARA 313) (CERCLA)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 2%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM;150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BUTANE; (N-BUTANE)
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: 8%
OSHA PEL:800 PPM
ACGIH TLV:800 PPM
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 17%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT
Ingred Name:ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER; (P.M. ACETATE)
CAS:108-65-6
RTECS #:AI8925000
Fraction by Wt: 8%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACRYLIC POLYMER
CAS:25068-63-7
Fraction by Wt: 13%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:NITROCELLULOSE; (CELLULOSE, NITRATE)
CAS:9004-70-0
RTECS #:QW0970000
Fraction by Wt: 2%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES:MAY CAUSE SEV IRRIT. LIQ
CONT MAY CAUSE SEV CORNEAL INJURY. SKIN:MAY CAUSE IRRIT. RPTD &
PRLNG CONT MAY CAUSE ALLERGIC DERM. INHAL:EXPOS TO HIGH CONCS OF
VAPS MAY CAUSE DIZZ, BRTHG DFCLTY,HDCHS/RESP IRRIT. EXTREMELY
HIGH CONCS MAY CAUSE DROW, STAG, CONFUSN, UNCON, COMA/DEATH. EXCESS
INHAL (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:OF VAPS CAN CAUSE NASAL & RESP IRRIT.
LIQ/VAP MAY BE IRRIT TO SKIN, EYES, THROAT/LUNGS. INTENTIONAL
MISUSE BY DELIB CONC & INHAL CONTENTS CAN BE HARMFUL/FATAL.
INGEST:MOD TOX. MAY CAUSE STOM DISCOMFORT, NAUS, VOMIT, DIARR &
NARCOS. ASPIR INTO LUNGS IF SWALLOWED/BY VOMIT CAN CAUSE CHEM PNEUM
WHICH CAN (ING 18)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:IMMED FLUSH W/PLENTY OF WATER FOR AT LST 15 MINS. GET MED
ATTN, IF IRRIT PERSISTS. SKIN:WASH THORO W/SOAP & WATER. SEEK MED
ATTN. REMOVE & LAUNDER CONTAM CLTHG BEFORE REUSE. INHAL:MOVE PERS
TO FRE SH AIR. IF BRTHG STOPS, APPLY ARTF RESP& SEEK MED ATTN.
INGEST:DECISION WHETHER TO INDUCE VOMIT/NOT MUST BE MADE BY MD
AFTER CAREFULY CONSIDERATION OF ALL MATLS INGESTED.
===================== Fire Fighting Measures =====================
Flash Point:-25F,-32C
Lower Limits:0.3%
Upper Limits:13.1%
Extinguishing Media:DRY CHEMICAL, CO*2 OR FOAM. WHEN FIGHTING FIRE
INVOLVING ALUMINUM FLAKE, DO NOT USE WATER/HALOGENATED EXTING
AGENTS.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER SPRAY SHOULD NOT BE USED EXCEPT TO KEEP DOWN VAPS/COOL CLSD
CNTNRS TO PVNT BUILD-UP OF PRESS. IF (SUPDAT)
Unusual Fire/Explosion Hazard:CONTENTS UNDER PRESS. DO NOT USE/STORE
NEAR SOURCES OF HEAT, SPKS/OPEN FLAME. KEEP AWAY FROM ANY SOURCE OF
HEAT SUCH AS SUNLIGHT, HEATERS/STOVES THAT (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID HEAT,
SPARKS, FLAMES & ANYTHING WHICH COULD CAUSE FIRE. VENTILATE AREA OF
SPILL & ADJACENT LOW LYING AREAS. AVOID BREATHING SOLVENT VAPORS.
REMOVE W/INERT ABSORBE NT MATERIALS & NON-SPARKING TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY AREA
W/VENTILATION SUITABLE FOR STORING MATERIALS SHOWN IN INGREDIENTS
SECTION. DO NOT STORE AT TEMPERATURES ABOVE 120F.
Other Precautions:STORE IN A COOL PLACE AWAY FROM DIRECT SUNLIGHT OR
ANY SOURCE OF IGNITION. SMOKE IN DESIGNATED AREAS ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF WORKPLACE EXPOSURE LIMITS ARE EXCEEDED FOR
ANY COMPONENT, A NIOSH APPROVED RESPIRATOR SUITABLE FOR COMPONENTS
LISTED IS RECOMMENDED.
Ventilation:LOC EXHST:SUFFICIENT VENT, IN VOL & PATTERN, SHOULD BE
PROVIDED TO KEEP CONTAM BELOW CURRENT APPLIC OSHA EXPOS (SUPDAT)
Other Protective Equipment:ANSI APPRVD EYE WASH FOUNTAIN & DELUGE
SHOWER . APPROP IMPERVIOUS CLTHG IS REC IF PRLNG/RPTD CONTACT IS
LIKELY.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING. WASH
HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health
FIRE FIGHT PROC:WATER IS USED, FOG NOZZ ARE PREF. VENT:LIMS/ACGIH'S TLV
LIMS. EYE PROT:FULL LGTH FCSHLD . EXPLO HAZ:COULD CAUSE CNTNR TO
BURST. DO NOT PUNCTURE/INCIN. DO NOT CRUSH/PLACE IN GARBA GE
COMPACTOR. DO NOT STORE >120F. AEROSOL CNTNRS MAY EXPLODE WHEN
EXPOS TO EXTREME HEAT. PROD VAPS ARE HVR/AIR &(ING 17)
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:>-44F,>-42C
Vapor Density:HVR/AIR
Spec Gravity:0.75-0.78
Evaporation Rate & Reference:FASTER THAN BUTYL ACETATE
Appearance and Odor:OPAQUE LIQUID; SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALUMINUM FLAKE CAN REACT VIOLENTLY W/HALOGENATED HYDROCARBS INCL
HALOGENATED EXTING AGENTS; ACIDS & CAUSTIC SOLNS.
Stability Condition to Avoid:AVOID CONTACT W/HEAT, SPARKS & OPEN FLAME.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY PRODUCE
CARBON DIOXIDE, CARBON MONOXIDE & UNIDENTIFIABLE ORGANIC MATERIALS.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE IN CLOSED CONTAINERS. DISPOSE OF PRODUCT
I/A/W LOCAL, COUNTY, STATE & FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:NON-ALKALINE GEL SOLUTION A
CAGE:21701
CAGE:30003
CAGE:21701
============= Composition/Information on Ingredients =============
Ingred Name:MIXTURE OF UNSATURATED AND LINEAR FATTY ACIDS
Fraction by Wt: 100%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:.
Medical Cond Aggravated by Exposure:.
===================== Fire Fighting Measures =====================
Flash Point:.
================== Accidental Release Measures ==================
Spill Release Procedures:.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:.
Ventilation:.
Other Protective Equipment:.
Work Hygienic Practices:.
Supplemental Safety and Health
MATERIAL WAS LAST MADE IN THE 1960'S, PRIOR TO ANY REQUIREMENT FOR AN
MSDS AND THUS NO MSDS IS AVAILABLE FROM MANUFACTURER. MANUFACTURER
DID SUPPLY INFORMATION CONCERNING THE FORMULATION OF THE MATER IAL.
THAT INFORMATION IS CONTAINED IN THIS RECORD
| 1 |
gloves_mandatory
|
=======================================================
Product ID: NUXTRA CALCIUM 8%, 0114050
Cage: 63182
Box: 365
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 63182
Box: 365
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: WARNING-CAUSES EYE IRRITATION. MAY CAUSE SKIN IRRITATION.
INGESTION CAUSES GI IRRITATION, VOMITING, DEPRESSION. INHALATION OF
CONCENTRATED VAPORS MAY CAUSE RESPIRATORY TRACT IRRITATION, HEADACHE, INCO
ORDINATION, NARCOSIS AND NERVOUS SYSTEMEFFECTS. ASPIRATION HAZARD IF
SWALLOWED-CAN ENTER LUNGS & CAUSE DAMAGE.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL: REMOVE TO FRESH AIR AND GIVE ARTIFICIAL RESPIRATION OR OXYGEN
IF NEEDED. CALL A PHYSICIAN. INGEST: DO NOT INDUCE VOMITING. CONTAINS
PETROLEUM DISTILLATES. ASPIRATION MAY LEAD TO PNEUMONITIS. CA LL A PHYSICIAN.
EYES: FLUSH WITH PLENTYOF WATER FOR AT LEAST 15 MINUTES. SKIN: WASH WITH SOAP
AND WATER. CALL A PHYSICIAN IF IRRITATION PERSISTS.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE SOURCES OF IGNITION AND VENTILATE AREA. COVER
W/INERT, ABSORBENT MATERIAL AND REMOVE TO DISPOSAL CONTAINER. OBSERVE ALL
RELEVANT FEDERAL, STATE AND LOCAL LAWS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: OBEY RELEVANT LOCAL, STATE AND FEDERAL LAWS. DO NOT
CONTAMINATE ANY LAKES, STREAMS, PONDS OR UNDERGROUND WATER SUPPLY. DISPOSE OF
IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS (FP N).
Handling And Storage Precautions: WARNING-COMBUST LIQ. KEEP AWAY FROM HEAT
& FLAME. MAY BE HARMFUL IF SWALLOWED. AVOID EYE & SKIN CONT. AVOID
BRTHG VAPS. USE W/ADEQ VENT.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: 108F,42C
Lower Limits: 0.9%
Upper Limits: 6%
Extinguishing Media: WATER SPRAY, FOAM, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N). BURNING WILL PRODUCE TOXIC FUMES. AVOID SPREADING LIQUID
AND FIRE BY WATER FLOODING.
Unusual Fire/Explosion Hazard: EXPOSURE TO HEAT BUILDS UP PRESSURE IN CLOSED
CONTAINERS. COOL W/WATER SPRAY.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF EXPOSURE EXCEEDS TLV, USE APPROPRIATE NIOSH/MSHA
APPROVED RESPIRATORY PROTECTIVE EQUIPMENT.
Ventilation: LOCAL EXHAUST/MECHANICAL: RECOMMENDED.
Other Protective Equipment: EYE WASH FOUNTAIN, SAFETY SHOWER.
Work Hygienic Practices: WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >300F,>149C
Vapor Pres: <10@25C
Vapor Density: GTR/AIR
Spec Gravity: 0.87
Evaporation Rate & Reference: SLOWER THAN BUTYL ACETATE
Solubility in Water: NEGLIGIBLE
Appearance and Odor: CLEAR LIQUID, PETROLEUM DISTILLATE ODOR.
Percent Volatiles by Volume: 49
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: STRONG OXIDANTS.
Hazardous Decomposition Products: BURNING WILL PRODUCE TOXIC FUMES.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: NUXTRA CALCIUM 8%, 0114050
Cage: 63182
Company Name: HULS AMERICA INC
Street: TURNER PLACE
PO Box: 365
Zipcode: 08855
Label Required IND: Y
Date Of Label Review: 01/25/1993
Status Code: C
Label Date: 01/25/1993
Origination Code: G
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: WARNING-COMBUSTIBLE LIQUID. KEEP AWAY FROM HEAT AND
FLAME. ACUTE: WARNING-CAUSES EYE IRRITATION. MAY CAUSE SKIN IRRITATION.
INGESTION CAUSES GI IRRITATION, VOMITING, DEPRESSION. INHALATION OF CONCENTR
ATED VAPORS MAY CAUSE RESPIRATORY TRACTIRRITATION, HEADACHE, INCOORDINATION,
NARCOSIS AND NERVOUS SYSTEM EFFECTS. ASPIRATION HAZARD IF SWALLOWED-CAN ENTER
LUNGS AND CAUSE DAMAGE. CHRONIC: NONE LISTEDBY MANUFACTURER.
=======================================================
| 1 |
gloves_mandatory
|
=======================================================
Product ID: ANTI SEIZE LUBRICANT, 80470
Cage: 05972
=======================================================
Contractor Summary
=======================================================
Cage: 05972
=======================================================
Ingredients
=======================================================
Cas: 112945-52-5
% Wt: 0.1-1
OSHA PEL: 6 MG/M3
ACGIH TLV: 10 MG/M3 TDUST
------------------------------
Cas: 75-56-9
RTECS #: TZ2975000
% Wt: 0.1-0.5
OSHA PEL: 100 PPM
ACGIH TLV: 20 PPM; 9293
EPA Rpt Qty: 100 LBS
DOT Rpt Qty: 100 LBS
------------------------------
Cas: 75-09-2
RTECS #: PA8050000
% Wt: 60-65
OSHA PEL: 500 PPM;1000 PPM, C
ACGIH TLV: 50 PPM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 64742-54-7
RTECS #: PY8035500
7%.
% Wt: 15-20
OSHA PEL: 300 PPM
ACGIH TLV: 300 PPM
------------------------------
Cas: 7440-50-8
RTECS #: GL5325000
% Wt: 5-10
OSHA PEL: 0.1MG/M3 FUME;1 DUST
ACGIH TLV: 0.2MG/M3 FUME;1 DUST
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 7782-42-5
RTECS #: MD9659600
% Wt: 5-10
OSHA PEL: 15 MPPCF RDUST
ACGIH TLV: 2 MG/M3 RDUST; 9293
------------------------------
Cas: 64742-65-0
RTECS #: PY8038500
LEL: 0.9%. UEL: 7%.
% Wt: 3-5
OSHA PEL: 5 MG/M3 (OIL MIST)
ACGIH TLV: 5 MG/M3 (OIL MIST)
------------------------------
Cas: 7429-90-5
RTECS #: BD0330000
% Wt: 1-3
OSHA PEL: 15MG/M3 DUST;5 FUME
ACGIH TLV: 10MG/M3 DUST
------------------------------
Cas: 124-38-9
RTECS #: FF6400000
% Wt: 1-3
OSHA PEL: 5000 PPM
ACGIH TLV: 5000PPM/30000STEL;93
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: EYE IRRITANT. MODERATELY TOXIC BY INGESTION. MAY CAUSE
HEADACHE, NAUSEA, DIZZINESS. NARCOSIS AT HIGH CONCENTRATION. CHLOROCARBON
MATLS HAVE PRDCED SENSIT OF MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS &
MAY HAVE A SIMILAR EFT IN HUMANS. ADRENOMIMETICS (E.G., EPINEPHRINE) MAY BE
CONTRAINDICATED EXCEPT FOR (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: METHYLENE CHLORIDE: GROUP 2B (IARC), GROUP 2
(NTP); PROPYLENE OXIDE: GROUP 2A (IARC), GROUP 2 (NTP).
Signs And Symptions Of Overexposure: HLTH HAZ: LIFE-SUSTAINING USES IN HUMANS
ACUTELY OR CHRONICALLY EXPOSED TO CHLOROCARBONS (FP N).
Medical Cond Aggravated By Exposure: GRAPHITE POWDER: EMPHYSEMA, ASTHMA.
First Aid: INGEST: INDUCE VOMITING. OBTAIN MEDICAL ATTENTION. INHAL: REMOVE TO
FRESH AIR. IF SYMPTOMS PERSIST, OBTAIN MEDICAL ATTENTION. SKIN: FLUSH
W/WATER. EYES: FLUSH AT LEAST 15 MINUTES W/WATER. OBTAIN MEDIC AL ATTENTION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: MAINTAIN ADEQUATE VENTILATION. SOAK UP WITH AN INERT
ABSORBENT. STORE IN A CLOSED CONTAINER UNTIL DISPOSAL.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: INCINERATE FOLLOWING EPA AND LOCAL, STATE, AND FEDERAL
REGULATIONS. DO NOT INCINERATE PRESSURIZED CANS.
Handling And Storage Precautions: STORE BELOW 110F TO PRESERVE SHELF LIFE. KEEP
AWAY FROM EYES. AVOID PRLNG BRTHG OF VAPORS AND SKIN CONTACT.
Other Precautions: NO SMKG IN AREA OF USE. DO NOT USE IN GEN VICINITY OF ARC
WELDING, OPEN FLAMES OR HOT SURFACES. HEAT &/OR UV RADIATION MAY CAUSE
FORMATION OF HCL &/OR PHOSGENE (FP N). THIS PROD CNTNS TOX CHEM SUBJECT
TO SARA SEC 313 & 40 CFR 372 REPORTING.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: NONE
Lower Limits: SEE INGRED
Upper Limits: SEE INGRED
Extinguishing Media: CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA &
FULL PROTECTIVE EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE. HAZARDOUS PRODUCTS FORMED BY FIRE/THERMAL
DECOMP: TOXIC CHLORIDES, METAL VAPORS. THERMAL DECOMP PRODUCTS MAY INCLUDE
HCL & PHOSGENE (FP N).
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N).
Ventilation: SUFFICIENT TO MAINTAIN VAPOR CONCENTRATION BELOW TLV.
Other Protective Equipment: NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: V3
B.P. Text: 100F,38C
Vapor Pres: 350 @ 75F
Vapor Density: 2.9
Spec Gravity: 1.3 (BASE ONLY)
Evaporation Rate & Reference: N/K (ETHER = 1)
Solubility in Water: NIL
Appearance and Odor: METALLIC LIQUID, SHARP ODOR.
Percent Volatiles by Volume: 0.32
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: SOLVENT MAY REACT VIOLENTLY WITH ALUMINUM ON PROLONGED
CONTACT.
Hazardous Decomposition Products: NONE. HCL, PHOSGENE (FP N).
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 31314
Product ID: ANTI SEIZE LUBRICANT, 80470
Review Date: 03/04/1993
Multiple KIT Number: 0
Review IND: Y
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: DTJ
Symbols: D
DOT Proper Shipping Name: CONSUMER COMMODITY
Hazard Class: ORM-D
Label: NONE
Non Bulk Pack: 156,306
Bulk Pack: NONE
Max Qty Pass: 30KGGROSS
Max Qty Cargo: 30KGGROSS
Vessel Stow Req: A
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: AIY
IMO Proper Shipping Name: AEROSOL DISPENSERS ?
IMO PSN Modifier: ,WITH A CAPACITY OF 1000 CUBIC CM OR LESS
IMDG Page Number: 9022
UN Number: 1950
UN Hazard Class: 9?
IMO Packaging Group: -
Subsidiary Risk Label: -
EMS Number: 2-13
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ALS
IATA UN ID Num: 1950
IATA Proper Shipping Name: AEROSOLS, FLAMMABLE
IATA PSN Modifier: (EACH NOT EXCEEDING 1 L CAPACITY)
IATA UN Class: 2.1
IATA Label: FLAMMABLE GAS
Packing Note Passenger: 203
Max Quant Pass: 75KG
Max Quant Cargo: 150KG
Packaging Note Cargo: 203
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ALS
AFI Proper Shipping Name: AEROSOLS, NONFLAMMABLE, N.O.S.
AFI PSN Modifier: CONTAINING SUBSTANCES IN CLASS 8, PACKING GROUP I OR II
AFI Hazard Class: FORB
Back Pack Reference: FORBIDDEN
=======================================================
HAZCOM Label
=======================================================
Product ID: ANTI SEIZE LUBRICANT, 80470
Cage: 05972
Company Name: LOCTITE CORPORATION
Street: 1001 TROUT BROOK CROSSING
Zipcode: 06067-3910
Label Required IND: Y
Date Of Label Review: 02/21/1992
Status Code: C
Label Date: 02/21/1992
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: MODERATELY TOXIC IF SWALLOWED. INHALATION CAN
CAUSE HEADACHE, NAUSEA, DIZZINESS AND NARCOSIS AT HIGH CONCENTRATION. CAN
CAUSE EYE IRRITATION.KEEP AWAY FROM EYES. AVOID PROLONGED BREATHING OF VA
POR. AVOID PROLONGED SKIN CONTACT. CHRONIC EFFECTS: THIS PRODUCT CONTAINS
METHYLENE CHLORIDE AND PROPYLENE OXIDE WHICH MAY CAUSE CANCER.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:73-1181 ELECTROLYTE, GAS SENSOR
CAGE:51906
CAGE:51906
============= Composition/Information on Ingredients =============
Ingred Name:SULFURIC ACID (SARA 302/313) (CERCLA)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 40%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3/3 STEL; 9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY CAUSE EYES, NOSE, THROAT
IRRITATION; BRONCHITIS, CONJUNCTIVITIS, STOMATITIS, DENTAL EROSION,
SKIN AND EYE BURNS, DERMATITIS, MAY BE FATAL IF INGESTED. CHRONIC:
PROLONGED OR REPEATED EXPOSUR E MAY CAUSE PULMONARY EDEMA,
EMPHYSEMA.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:EYES, NOSE, THROAT IRRITATION; BRONCHITIS,
CONJUNCTIVITIS, STOMATITIS, DENTAL EROSION, SKIN AND EYE BURNS,
DERMATITIS, MAY BE FATAL IF INGESTED.
Medical Cond Aggravated by Exposure:NONE IDENTIFIED.
======================= First Aid Measures =======================
First Aid:EYES-IMMEDIATELY FLUSH WITH WATER FOR 15 MINUTES. CALL
PHYSICIAN. SKIN-IMMEDIATELY FLUSH WITH WATER. INHALED-REMOVE TO
FRESH AIR. ADMINISTER OXYGEN OR ARTIFICIAL RESPIRATION AS NEEDED.
INGESTED-DO NOT INDUCE VOMITING! CALL PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:NONE.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR APPROPRIATE PERSONAL PROTECTIVE
CLOTHING/EQUIPMENT. NEUTRALIZE SPILL WITH SODA ASH, LIME OR BAKING
SODA. ABSORB WITH SPILLED MATERIAL WITH ABSORBENT MATERIAL. FLUSH
AREA WITH WATER.
Neutralizing Agent:SODA ASH, LIME, BAKING SODA.
======================Handling and Storage ======================
Handling and Storage Precautions:SUITABLE FOR GENERAL STORAGE. USE SAFE
CHEMICAL HANDLING PROCEDURES. DO NOT ATTEMPT TO DISASSEMBLE THE
CELL.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:NONE NORMALLY REQUIRED.
Other Protective Equipment:APRON. DLA-HMIS: EYE WASH AVAILABLE.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:250F,121C
Vapor Density:3.4
Spec Gravity:1.03-1.73
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID IN SEALED ELECTROCHEMICAL SENSOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ORGANIC MATERIALS, CHLORATES, CARBIDES, FULMINATES, POWDERED METALS,
MOISTURE.
Stability Condition to Avoid:REACTS EXOTHERMICALLY WITH WATER.
CORROSIVE TO ORGANIC MATERIALS.
Hazardous Decomposition Products:OXIDES OF SULFUR.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL ENVIRONMENTAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:LEAD NITRATE, L6258
CAGE:0DK69
CAGE:0DK69
============= Composition/Information on Ingredients =============
Ingred Name:LEAD (II) NITRATE (1:2); (LEAD NITRATE) (SARA 313)
CAS:10099-74-8
RTECS #:OG2100000
OSHA PEL:SEE 1910.1025
ACGIH TLV:0.15 MG(PB)/M3
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:SUP DAT: TARGET ORGAN DATA: PATERNAL EFTS (TESTES,
EPIDIDYMIS, SPERM DUCT), MATERNAL EFTS (PARTITURITION), EFTS (INF
3)
RTECS #:9999999ZZ
Ingred Name:ING 2: ON FERTILITY (POST-IMPLANTATION MORTALITY, OTHER
MEASURES OF FERTILITY), EFTS ON EMBRYO/FETUS (EXTRA (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3: EMBRYONIC STRUCTURES, FETOTOXICITY, FETAL DEATH),
SPECIFIC DEVEL ABNORM (CNS, BODY WALL, MUSCULOSKELETAL (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: SYS, CARDIOVASCULAR SYS, UROGENITAL SYS,
HOMEOSTASIS, OTHER DEVEL ABNORM), EFTS ON NEWBORN (WEANING OR (ING
6)
RTECS #:9999999ZZ
Ingred Name:ING 5: LACTATION INDEX, GROWTH STATISTICS, BEHAVIORAL). TO
BEST OF MFR KNOWLEDGE, CHEM, PHYSICAL & TOXICOLOGICAL (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: PROPERTIES HAVE NOT BEEN THOROUGHLY INVESTIGATED.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH: SULFIDE WITH SODIUM HYPOCHLORITE.
NEUTRALIZE THE SOLUTION BEFORE FLUSHING DOWN THE DRAIN. (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: OBSERVE ALL FEDERAL, STATE, AND LOCAL ENVIRONMENTAL
REGULATIONS.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: OF ALKYL NITRATES. MIX OF NITRATE
W/PHOSPHOROUS, TIN (2) CHLORIDE/OTHER REDUCING AGENTS MAY REACT
(ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: EXPLO. MIX OF METAL NITRATES & PHOSPHINATES EXPLODE
ON HEATING. MIX CONTAINING NITRATES, NITRITES, & (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: ORGANIC MATLS ARE POTENTIALLY DANGEROUS, ESPECIALLY
IN THE PRESENCE OF ACIDIC MATLS & HEAVY METALS. (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: INCOMPATIBLE WITH: CYANIDES, THIOCYANATES,
ISOTHIOCYANATES, HYPOPHOSPHITES.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY BE HARMFUL BY INHAL,
INGEST/SKIN ABSORPTION. EYE & SKIN IRRIT. IRRIT TO MUC MEMBS &
UPPER RESP TRACT. ABSORPTION INTO BODY LEADS TO FORM OF
METHEMOGLOBIN WHICH, IN SUFFICIENT CONC, CAUSES C YANOSIS. ONSET
MAY BE DELAYED 2-4 HRS/LONGER. CHRONIC: MAY CAUSE REPRO DISORDERS.
TARGET ORGANS: BLOOD,(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: KIDNEYS, NERVES. PRLNG/RPTD EXPOS TO
DUST MAY RSLT IN WEAK, NAUS, VOMIT, ABDOM PAIN, HDCH & BLUE-GREEN
LINE ON GUMS. BLOOD CHANGES, KIDNEY & CNS DMG. LEAD SALTS HAVE BEEN
REPORTED TO CROSS P LACENTA & INDUCE EMBRYO- & FETO- MORTALITY.
THEY ALSO HAVE TERATOGENIC EFTS IN SOMA ANIMAL SPECIES. ADVERSE
(SUP DAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF WATER
FOR AT LEAST 15 MINUTES WHILE REMOVING CONTAMINATED CLOTHING AND
SHOES. INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTIFICIAL RE SPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN.
INGESTION: WASH OUT MOUTH WITH WATER PROVIDED PERSON IS CONSCIOUS.
CALL MD. WASH CONTAMINATED CLOTHING BEFORE REUSE.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . STRONG OXIDIZER.
Unusual Fire/Explosion Hazard:CONTACT WITH OTHER MATERIAL MAY CAUSE
FIRE. EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR NIOSH/MSHA APPROVED SCBA,
ASH, PICK UP, KEEP IN CLOSED CONTAINER AND HOLD FOR WASTE DISPOSAL.
VENTILATE AREA AND W ASH SPILL SITE AFTER MATERIAL PICK UP IS
COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BRTHG DUST. DO NOT GET IN EYES,
ON SKIN, ON CLTHG. AVOID PRLNG/RPTD EXPOS. IRRIT. HARMFUL DUST.
REPRO HAZ. KEEP TIGHTLY CLSD.
Other Precautions:KEEP AWAY FROM COMBUST MATLS, HEAT, SPARKS, & OPEN
FLAME. STORE IN COOL, DRY PLACE. MIX OF ALUMINUM POWDER, WATER &
NITRATE MAY EXPLODE DUE TO SELF-ACCELERATING RXN. MIX OF METAL
NITRATES W/ALKYL ESTE RS MAY EXPLODE, OWING TO FORM (ING 10)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:WEAR PROTECTIVE CLOTHING. EMERGENCY EYEWASH
& DELUGE SHOWER MEETING ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE. WASH
THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
EFTS OF OVEREXP: EFTS OF LEAD ON HUMAN REPRO, EMBRYONIC & FETAL DEVEL &
POSTNATAL (E.G., MENTAL) DEVEL HAVE BEEN REPORTED. LEAD APPEARS ON
NAVY LIST OF OCCUP CHEM REPRO HAZ. SEEK CONSULTATION FROM APP ROP
HLTH PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG &
EXPOS INFO . (ING 2)
================== Physical/Chemical Properties ==================
Appearance and Odor:WHITE CRYSTALLINE POWDER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG REDUCING AGENTS, FINELY POWDERED METALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NITROGEN OXIDES, LEAD/LEAD OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:MATL SHOULD BE DISSOLVED IN 1)WATER; 2)ACID
SOLN/3)OXIDIZED TO WATER-SOLUBLE STATE. PRECIPITATE MATL AS
SULFIDE, ADJUSTING PH OF SOLN TO 7 TO COMPLETE PRECIPITATION.
FILTER INSOLUBLES & DISP OF THEM I N HAZ WASTE SITE. DESTROY ANY
EXCESS (ING 8)
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CELLULOSE ACETATE BUTYRATE, 077
CAGE:0MWG0
CAGE:0MWG0
============= Composition/Information on Ingredients =============
Ingred Name:CELLULOSE ACETATE BUTYRATE
CAS:9004-36-8
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE LISTED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MATERIALS THAT CONTACT EYE MAY BE
IRRITATING OR CAUSE MECHANICAL INJURY. LOW HAZARD FOR USUAL
HANDLING.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE LISTED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:IN ALL CASES, IF IRRITATION DEVELOPS, SEEK MEDICAL
ASSISTANCE. INHALATION: REMOVE FROM EXPOSURE. IF BREATHING STOPS,
BEGIN MOUTH TO MOUTH. EYES: FLUSH WITH WATER FOR AT LEAST 15
MINUTES. SKIN: WASH AF FECTED AREA WITH SOAP AND WATER. REMOVEDIRTY
CLOTHING. INGESTION: CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:POWDER MATERIAL MAY FORM EXPLOSIVE
DUST-AIR MIXTURES.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP AND PLACE IN CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE LISTED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN DRY COOL PLACE IN TIGHTLY
CLOSED CONTAINER.
Other Precautions:NONE LISTED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF NEEDED. WEAR NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:NOT APPLICABLE.
Work Hygienic Practices:GOOD HYGIENE SHOULD BE FOLLOWED.
Supplemental Safety and Health
NONE LISTED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:>261F,>127C
Spec Gravity:1.16-1.26
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE POWDER; CHARACTERISTIC BUTYRIC ACID ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL IN ACCORDANCE WITH STATE, FEDERAL AND
LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: 5060/5061 SILVER PASTE FOR EM
Cage: 1P573
Box: 656
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 66688
Cage: 1P573
Box: 656
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ING 1:TOX EFTS DESCRIBED IN ANIMALS INCL:SKIN/EYE IRRIT.
HUMAN HLTH EFTS OF OVEREXP MAY INCL:SKIN IRRIT W/DISCOMFORT/RASH, EYE IRRIT
W/DISCOMFORT, TEARING/BLURRING OF VISION. HUMAN EFTS OF HIGHER LEVE L
ACUTE/CHRONIC OVEREXP MAY INCL:IRRIT OF UPPER RESP PASSAGES, ABNORMAL
LIVER/KIDNEY FUNC AS DETECTED (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:BY LAB TESTS. ING 2:TOX EFTS
DESCRIBED IN ANIMALS INCL:SKIN/EYE IRRIT, BLOOD/KIDNEY/URINARY TRACT EFTS.
HUMAN HLTH EFTS OF OVEREXP MAY INCL:SKIN IRRIT W/DISCOMFORT/RASH, EYE IRRIT
W/DISCOMFOR T, TEARING/BLURRING OF VISION. HUMAN EFTS OF HIGHER LEVEL
ACUTE/CHRONIC OVEREXP MAY INCL:ABNORMAL BLOOD-FORMING (SUPDAT)
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: SKIN:IMMEDIATELY WASH W/SOAP & PLENTY OF WATER. EYE:IMMEDIATELY
FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINUTES. CALL MD IMMEDIATELY.
INHAL:REMOVE TO FRESH AIR IMMEDIATELY. IF NOT BREATHING, GIVE ARTF RESP,
PREFERABLY MOUTH-TO-MOUTH. IF BRTHG IS DIFFICULT, GIVE OXYGEN. CALL MD.
INGEST:IMMED GIVE 2 GLASSES OF WATER & INDUCE VOMIT. NEVER GIVE ANYTHING
BY MOUTH TO AN UNCONSCIOUS PERSON. CALL MD.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: FOR SM SPILLS:ABSORB ON RAGS, SAND/OTHER ABSORB MATL.
FOR LG SPILLS:GET WORKERS OUT OF AFFECTED AREA. IF FLAMM LIQS/VAPS MAY BE
PRESENT, TURN OFF ELEC DEVICES/OTHER SOURCES OF SPKS/FLAMES. WEAR PROT E
QUIP. USE NIOSH/MSHA APPRVD SUPPLIED-AIR
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS (FP N). COMPONENTS OF THIS PRODUCT MAY BE CONSIDERED HAZARDOUS,
WASTE PRODUCT MAY BE REFINED TO RECOVER PRECIOUS METAL CONTENT.
Handling And Storage Precautions: STORE PRODUCT IN COOL, DRY LOCATION. DO NOT
STORE FLAMMABLE MATERIALS IN AREAS WHERE VAPORS MAY COME INTO CONTACT
W/FLAMES, SPARKS OR HEAT.
Other Precautions: STORE PRODUCT <90F TO ENSURE PRODUCT VISCOSITY STABLITY.
DO NOT SMOKE, CONSUME OR STORE FOOD OR DRINKS IN AREAS WHERE PRODUCT IS
HANDLED OR STORED. OBSERVE LABEL PRECAUTIONS.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: CC
Flash Point Text: 128F,53C
Extinguishing Media: WATER SPRAY, DRY CHEMICAL OR CARBON DIOXIDE.
Fire Fighting Procedures: USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP (FP
N). TOX DECOMP PRODS MAY FORM UNDER FIRE CNDTNS. DECONTAM CONTAM CLTHG &
EQUIP W/SOAP & WATER, DISP OF (SUPDAT)
Unusual Fire/Explosion Hazard: KEEP AWAY FROM SPKS & OPEN FLAMES. DO NOT
SMOKE IN AREA W/OPEN PROD. IF PROD MAY BE HEATED ABOVE ITS FLASHPOINT DURING
PROCESSING, REMOVE SOURCES OF (SUPP DATA)
=======================================================
Control Measures
=======================================================
Respiratory Protection: SELECTION OF SUITABLE RESP WILL DEPEND ON PROPERTIES OF
CONTAMS & THEIR ACTUAL/EXPECTED AIR CONCS VERSUS APPLIC LIMS. CONSULT
ANSI STD Z68.2 FOR DECISION LOGIC TO SELECT APPROP NIOSH/MSHA APPRVD RESPS ,
IF RESPS ARE NEEDED TO MEET
Ventilation: ADEQ LOC VENT SHOULD BE USED TO KEEP EXPOS BELOW APPLIC LIMS:OTHER
ENGINEERING CONTROLS SUCH AS TOTALLY ENCLSD
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N). PROT OUTER CLTHG SHOULD BE USED WHEN
Work Hygienic Practices: WASH HANDS THORO AFTER HNDLG & BEFORE EATING/SMOKING.
AFTER HNDLG PROD, WASH HANDS THORO BEFORE LEAVING WORK AREA.
Supplemental Safety and Health: NOTE:USERS OF "L" VERSION SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). FIRE FIGHT PROC:RESIDUES PER FED, STATE &
LOC REGS. EXPLO HAZ:IGNIT SUCH AS OPEN SPKS, FLAMES/STATIC DISCHARGE TO PVNT
VAP IGNIT. EFTS OF OVEREXP:SYS FUNC W/ANEMIA, ABNORMAL KIDNEY FUNC AS
DETECTED BY LAB TESTS. IN ADDN:SKIN PERMEATION
=======================================================
Physical/Chemical Properties
=======================================================
Solubility in Water: SLIGHT
Appearance and Odor: VISCOUS, GREY LIQUID; AROMATIC ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: MATERIAL UNDER NORMAL LABORATORY USAGE CONDITIONS
IS STABLE.
Materials To Avoid: AVOID CONTACT W/OXIDIZING AGENTS, BASES.
Hazardous Decomposition Products: DECOMP PRODS AT HIGH TEMP MAY INCL:CARBON
MONOXIDE, CARBON DIOXIDE, WATER, ETHYL METHACRYLATE, METHYL ACRYLATE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: 5060/5061 SILVER PASTE FOR EM
Cage: 1P573
Company Name: STRUCTURE PROBE INC
PO Box: 656
Zipcode: 19381-0656
Label Required IND: Y
Date Of Label Review: 09/07/1995
Status Code: C
Label Date: 09/07/1995
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE:SKIN:IRRITATION. EYES:IRRITATION.
CHRONIC:ANIMAL STUDIES CLEARLY DEMONSTRATED DOSE-RELATED ADVERSE EFFECTS ON
THE CENTRAL NERVOUS SYSTEM, BLOOD-FORMING TISSUES, BLOOD, KIDNEYS & LIV
ER, ASSOCIATED W/ADMINISTRATION OF ETHYLENE GLYCOL MONOBUTYL ETHER ACETATE
(EGBEA) (FP N).
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:BUTYL CELLOSOLVE, R6 K 25
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2-BUTOXY-; (EGBE). VP:0.6
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 100%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
Ingred Name:VOLATILE ORGANIC COMPOUNDS (7.49 LB 898 GM)
RTECS #:9999999VO
Ingred Name:SUPP DATA:(EXTRACTED FROM DHHS (NIOSH) PUBLICATION NO.
90-118) .
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:DELIBERATELY CONCENTRATING & INHALING THE
CONTENTS CAN BE HARMFUL OR FATAL.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:APPRVD DUST/MIST RESPIRATOR FOR DUST WHICH MAY BE
GENERATED FROM THIS PROD, UNDERLYING PAINT OR THE ABRASIVE.
RTECS #:9999999ZZ
Ingred Name:VENT:LIMITS. REFER TO OSHA STANDARDS 1910.94, 1910.107,
1910.108.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRIT OF EYES, SKIN & RESP SYS.
MAY CAUSE NERV SYS DEPRESS. EXTREME OVEREXPOS MAY RSLT IN
UNCON/POSS DEATH. HDCH/DIZZ/NAUS/LOSS OF COORD ARE INDICATIONS OF
EXCESSIVE EXPOS TO VAPS/SPRAY MISTS. REDNESS/ITCHING/BURNING
SENSATION MAY INDICATE EYE/EXCESSIVE SKIN EXPOS. CHRONIC: PRLNGD
OVEREXPOS TO (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:SOLV INGREDS IN INGRED SECTION MAY
CAUSE ADVERSE EFTS TO LIVER/URINARY/BLOOD FORMING SYSTEMS. RPTS
HAVE ASSOC RPTD/PRLNGD OVEREXPOS TO SOLV W/PERM BRAIN & NERV SYS
DAM. ANIMAL STUDIES HAVE CL EARLY DEMONSTRATED DOSE-RELATED
ADVERSEEFTS ON CNS, HEMATOPOIETIC TISS, BLOOD, KIDNEYS & LIVER
ASSOC W/ADMIN (SUP DAT)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL:IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE BREATHING.
KEEP WARM & QUIET. SKIN:WASH AFFECTED AREA THOROUGHLY W/SOAP &
WATER. REMOVE CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE.
EYES:FLUSH W/LARG E AMOUNTS OF WATER FOR AT LEAST 15 MINS. GET
MEDICAL ATTENTION. INGEST:CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:138F,59C
Lower Limits:1.1
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL & FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER SPRAY MAY BE INEFT. IF WATER IS USED, FOG NOZZ ARE PREF.
WATER MAY BE USED TO COOL CLSD (SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY CLSD. ISOLATE FROM
HEAT/ELEC EQUIP/SPARKS/OPEN FLAME. CLSD CONTRS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. APPLICATN TO HOT SURF (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE &
REMOVE W/INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTENTS ARE COMBUSTIBLE. KEEP AWAY
FROM HEAT/OPEN FLAME. KEEP CONTR CLSD WHEN NOT IN USE. USE ONLY
W/ADEQ VENT. AVOID BRTHG VAP/SPRAY MIST.
Other Precautions:AVOID CONT W/SKIN & EYES. CONSULT NFPA CODE. USE
APPRVD BONDING & GROUNDING PROCEDURES. TRANSFER ONLY TO APPRVD
CONTRS W/COMPLETE & APPROP LABELING. DO NOT TAKE INTERNALLY. KEEP
OUT OF REACH OF CHILDR EN. INTENTIONAL MISUSE BY (ING 4)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIMITS BY VENT, WEAR A PROPERLY FITTED NIOSH/MSHA APPRVD ORG
VAP/PARTICULATE RESP FOR PROT AGAINST MATLS IN INGRED SECTION. WHEN
SANDING/ABRADING DR IED FILM, WEAR A NIOSH/MSHA (ING 5)
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPTABLE IF EXPOS TO MATLS IN
INGRED SECTION IS MAINTAINED BELOW APPLIC EXPOS (ING 6)
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC:CONTRS TO PVNT PRESS BUILD-UP & POSS
AUTOIGNITION/EXPLOS WHEN EXPOSED TO EXTREME HEAT. EXPLO HAZ:REQS
SPEC PRECS. DURING EMER CNDTNS OVEREXPOS TO DECOMP PRODS MAY CAUSE
HLTH HAZ. SYMPS MAY NOT BE IMMED APPARENT. OBTAIN MED ATTN. EFTS
OF OVEREXP:OF ETHYLENE GLYCOL MONOBUTYL ETHER (EGBE). (ING 3)
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:>336F,>169C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE & CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THIS PROD MAY BE HAZ AS DEFINED UNDER
THE RCRA 40CFR261. WASTE MUST BE TESTED FOR IGNITABILITY TO DETERM
APPLIC EPA HAZ WASTE NOS. INCIN IN APPRVD FACILITY. DO NOT INCIN
CLSD CONTR. DISP OF I/A/W FED, STATE & LOC REGS REGARDING
POLLUTION.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:14399 EDTA TETRASODIUM SALT 0.800-0.004 M
CAGE:4T252
CAGE:91224
CAGE:4T252
============= Composition/Information on Ingredients =============
Ingred Name:TETRASODIUM SALT OF ETHYLENEDIAMINETETRAACETIC ACID, SODIUM
EDTA, SODIUM (DI) ETHYLENEDIAMINE TETRAACETATE *96-3*
CAS:64-02-8
RTECS #:AH5075000
Fraction by Wt: <40%
Ingred Name:OTHER COMPONENTS
Fraction by Wt: <0.1%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: <100%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION. INGESTION: MAY
CAUSE GI IRRITATION & KIDNEY DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, CALCIUM DEFICIENCY IN THE BLOOD,
FEVER, MUSCULAR CRAMPS.
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: FLUSH W/PLENTY OF
WATER. INGESTION: GIVE LARGE AMOUNTS OF WATER. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, CO2, DRY CHEMICAL
Unusual Fire/Explosion Hazard:MAY EMIT TOXIC FUMES IN FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:COVER W/EXCESS SODA ASH/SODIUM BICARBONATE.
SCOOP SLURRY TO BEAKER. ADJUST PH TO BETWEEN 6 & 9. FLUSH TO THE
DRAIN W/EXCESS WATER. WASH SITE W/AN ALKALI SOLUTION.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE TIGHTLY CLOSED.
Other Precautions:AVOID CONTACT W/EYES & SKIN.
============= Exposure Controls/Personal Protection =============
Ventilation:RECOMMENDED
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
THE TRADE NAME FOR THIS PRODUCT IS EDTA TETRASODIUM SALT 0.800 +/-
0.004M.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Spec Gravity:1.16
pH:10.2
Evaporation Rate & Reference:(WATER = 1): 1.1
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR LIGHT YELLOW-GOLD LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:EVAPORATION, EXTREME TEMPS
Hazardous Decomposition Products:NITROGEN OXIDES & SODIUM OXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
======================================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SAMURAI
CAGE:0K209
CAGE:0K209
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:400 PPM
ACGIH TLV:400 PPM/500STEL;9394
Ingred Name:2-BUTOXYETHANOL (SARA III)
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: <8%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9394
Ingred Name:SODIUM PHOSPHATE, TRIBASIC (SARA III)
CAS:7601-54-9
RTECS #:TC9490000
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SODIUM TRIPOLYPHOSPHATE
CAS:7758-19-4
RTECS #:YK4750000
Other REC Limits:NONE RECOMMENDED
Ingred Name:TETRASODIUM ETHYLENE DIAMINE TETRAACETATE
CAS:64-02-8
RTECS #:AH5075000
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM METASILICATE, ANHYDROUS
CAS:6834-92-0
RTECS #:VV9275000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3 8HR
ACGIH TLV:C; 2 MG.M3
Ingred Name:SODIUM METASILICATE
CAS:6834-92-0
RTECS #:VV9275000
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:MAY CAUSE SEVERE
IRRITATION.SKIN:MAY CAUSE SEVERE IRRITATION.INGEST:CORROSIVE(SODIUM
METASILICATE).MAY CAUSE GI TRACT IRRITATION.INHAL:MISTS ARE
CORROSIVE(SODIUM METASILICATE).MAY CAUSE RESPIRATO RY
IRRITATION.CHRONIC:INGRED 2 IS DERMALLY ABSORBED IN HARMFUL
AMOUNTS(DAMAGES LIVER,KIDNEY,LUNG AND BLOOD FORMNG ORGANS
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of Overexposure:SKIN/EYES:BURNS.
Medical Cond Aggravated by Exposure:SKIN CONTACT MAY AGGRAVATE EXISTING
DERMATITIS.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH SOAP AND
WATER.EYES:FLUSH WITH WATER FOR 15 MINUTES.INHAL:REMOVE TO FRESH
AIR.GIVE OXYGEN OR ARTIFICIAL RESPIRATION IF NEEDED.INGEST:DO NOT
INDUCE VOMITING. GET PROMPT QUALIFIED MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:FOAM, DRY CHEMICAL, WATER SPRAY OR CARBON DIOXIDE.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.COOL FIRE EXPOSED CONTAINERS WITH WATER
FOG.
Unusual Fire/Explosion Hazard:MANUFACTURER STATES NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE SOURCES OF IGNITION.USE PROPER
RESPIRATORY AND PROTECTIVE EQUIPMENT.SHUT OFF LEAK IF
SAFE.DIKE.SOAK UP WITH A NON-COMBUSTIBLE INERT
ABSORBANT(CLAY,SAND);PLACE IN PROPER CONTAINER FOR DISPOSA L.WASH
SPILL AREA TO REMOVE SLIPPINESS.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:USE AND STORE AWAY FROM SOURCES OF
IGNITION, STRONG OXIDIZING AGENTS AND STRONG MINERAL ACIDS. KEEP
CONTAINER SEALED WHEN NOT IN USE.
Other Precautions:CORROSIVE MATERIAL.MINIMIZE BREATHING VAPOR OR MIST.
AVOID PROLONGED OR REPEATED CONTACT WITH SKIN. WASH CONTAMINATED
CLOTHING BEFORE REUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NEEDED IN NORMAL SERVICE.
Ventilation:USE GENERAL DILUTION VENTILATION.
Other Protective Equipment:PROVIDE A LOCAL EYE WASH STATION AND SAFETY
SHOWER.
Work Hygienic Practices:WASH HANDS.SEPERATE WORK CLOTHES FROM STREET
CLOTHES.LAUNDER WORK CLOTHES BEFORE REUSE.KEEP FOOD OUT OF THE WORK
AREA.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>180F,>82C
Vapor Pres:>17
Vapor Density:>1
Spec Gravity:1.04
Evaporation Rate & Reference:>1 (N-BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:BLUE AND CLEAR LIQUID WITH RUBBING ALCOHOL ODOR
Percent Volatiles by Volume:>90
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS.
Stability Condition to Avoid:HIGH HEAT,SOURCES OF IGNITION.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE,
HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:EP-P CARTRIDGE FOR LASER BEAM PRINTERY (SEE SUPP DATA)
Preparer's Name:JOSEPH PALMERI
CAGE:1BA63
CAGE:0S0F8
CAGE:1BA63
CAGE:0YL79
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE-ACRYLIC TERPOLYMER
Fraction by Wt: 45-55%
Ingred Name:IRON OXIDE
CAS:1317-61-9
Fraction by Wt: 45-55%
OSHA PEL:10 MG/M3
ACGIH TLV:5 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TONER POWDER IS NOT ACCESSIBLE, UNTIL
THE CARTRIDGE IS FORCED TO BE BROKEN. ACUTE:MINIMAL RESPIRATORY
TRACT IRRITATION MAY OCCUR AS W/EXPOSURE TO LARGE AMOUNTS ANY
NON-TOXIC DUST. NO DATA AVAILABLE FO R CHRONIC EFFECTS OF
OVEREXPOSURE.
Explanation of Carcinogenicity:MANUFACTURER GAVE NO INFORMATION ABOUT
CARCINOGENICITY. HMIS DOES NOT EXPECT IT TO BE CARCINOGENIC.
Effects of Overexposure:INHALATION:TONER IS FINELY DIVIDED SOLID. DO
NOT BREATHE THE DUST. EYE:ANY MATERIAL THAT CONTACTS THE EYE MAY BE
IRRITATING. NO SPECIFIC HAZARD KNOWN TO CANON. SKIN:LOW HAZARD FOR
INDUSTRIAL HANDLING .
Medical Cond Aggravated by Exposure:MFR GAVE NO INFORMATION ON MSDS.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE FROM EXPOSURE TO FRESH AIR. EYE:OPEN EYE &
FLUSH W/PLENTY OF WATER. IF IRRITATION PERSISTS GET MEDICAL
ATTENTION. SKIN:WASH W/SOAP AND WATER. INGESTION:DRINK SEVERAL
GLASSES OF WATER . CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, DRY CHEMICALS, CARBON DIOXIDE.
Fire Fighting Procedures:NONE.
Unusual Fire/Explosion Hazard:THIS MATERIAL, LIKE MOST ORGANIC MATERIAL
IN POWDER FORM, IS CAPABLE OF CREATING A DUST EXPLOSION.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP MATERIAL ONTO PAPER AND PLACE IN FIBER
CARTON.
Neutralizing Agent:MFR GAVE NO INFORMATION ON MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN. KEEP
FROM CONTACT W/OXIDIZING MATERIALS.
Other Precautions:MFR GAVE NO INFORMATION ON MSDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MFR GAVE NO INFORMATION ON MSDS.
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT.
Other Protective Equipment:NONE.
Work Hygienic Practices:MFR:? HMIS:USE GOOD INDUSTRIAL HYGIENE
PRACTICES. MINIMIZE CONTACT & WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
THE ITEM OF SUPPLY IS A TONER CARTRIDGE FOR USE W/HEWLETT-PACKARD
LASERJET PRINTERS. THE TONER IS APPARENTLY MANUFACTURERED BY CANON
AND THE CARTRIDGE IS SUPPLIED TO DOD BY AMERICAN LASER.
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NONE
Melt/Freeze Pt:M.P/F.P Text:>212F,>100C
Vapor Pres:NEGLIGIBLE
Spec Gravity:1.5-1.8
Evaporation Rate & Reference:NEGLEGIBLE (N-BUAC = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:FINE POWDER, SLIGHT PLASTIC ODOR
Percent Volatiles by Volume:NEGLIG
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:MFR GAVE NO INFORMATION ON MSDS.
Hazardous Decomposition Products:AS W/ANY OTHER ORGANIC MATERIAL,
DECOMPOSITION WILL PRODUCE CARBON DIOXIDE AND CARBON MONOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:NO SPECIAL DISPOSAL TECHNIQUE REQUIRED. ENSURE
COMPLIANCE WITH FEDERAL, STATE AND/OR LOCAL REGULATIONS. TONER MAY
BE CONSIDERED PLASTIC WASTE. CARTRIDGE IS CONSTRUCTED OF PLASTICS
AND METALS.
| 0 |
gloves_not_mandatory
|
=======================================================
NIIN: 00-582-5382
Product ID: SO SURE FLAT BLACK 37038 (14-390)
Cage: 0FTT5
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 0FTT5
=======================================================
Contractor Summary
=======================================================
Cage: 0FTT5
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: ENAMEL
Unit of Issue: PT
UI Container Qty: 0
=======================================================
Ingredients
=======================================================
Cas: 8030-30-6
RTECS #: DE3030000
% Wt: 4.40
Other REC Limits: NONE SPECIFIED
OSHA PEL: 300 PPM
ACGIH TLV: 300 PPM
------------------------------
Cas: 108-88-3
RTECS #: XS5250000
% Wt: 29.08
Other REC Limits: NONE SPECIFIED
OSHA PEL: 200 PPM/150 STEL
ACGIH TLV: 50 PPM; 9293
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 67-64-1
RTECS #: AL3150000
% Wt: 25.45
Other REC Limits: NONE SPECIFIED
OSHA PEL: 1000PPM
ACGIH TLV: 750PPM/1000STEL;9293
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 74-98-6
RTECS #: TX2275000
% Wt: 16.72
Other REC Limits: NONE SPECIFIED
OSHA PEL: 1000 PPM
ACGIH TLV: 1000 PPM
------------------------------
Cas: 75-28-5
RTECS #: TZ4300000
% Wt: 4.11
Other REC Limits: NONE SPECIFIED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 800 PPM
------------------------------
Cas: 106-97-8
RTECS #: EJ4200000
% Wt: 6.58
Other REC Limits: NONE SPECIFIED
OSHA PEL: 800 PPM
ACGIH TLV: 800 PPM
------------------------------
RTECS #: 9999999VO
Other REC Limits: NONE SPECIFIED
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: CONCENTRATING/INHALING CONTENTS HARMFUL/FATAL. REPORTS
ASSOCIATE REPEATED/PROLONGED OCCUPATIONAL OVEREXPOSURE W/PERMANENT
BRAIN/NERVOUS SYSTEM DAMAGE. CONFINED AREAS/HIGH CONCENTRATIONS ARE
ANESTHETIC . IRRITATION TO SKIN/RESPIRATORY TRACT.HARMFUL IF SWALLOWED.
SEVERE EYE IRRITATION.
Signs And Symptions Of Overexposure: IRRITATION TO EYES, THROAT, AND
RESPIRATORY TRACT. MAY CAUSE HEADACHES, NAUSEA, AND VOMITING. OVEREXPOSURE
MAY RESULT IN LIGHT HEADEDNESS, STAGGER, GIDDINESS, AND POSSIBLE NAUSEA.
Medical Cond Aggravated By Exposure: RESPIRATORY AILMENTS.
First Aid: SKIN/CLOTHES: WASH W/SOAP/WATER; WASH CLOTHES BEFORE REUSE. EYES:
FLUSH W/WATER 15 MIN/CONTACT PHYSICIAN/OHPHTALMOLOGIST IMMEDIATELY. INGEST:
DO NOT INDUCE VOMITING. GET IMMEDIATE MEDICAL AID. INHALE: MOVE TO FRESH
AIR/AFTIFICIAL RESPIRATION IF NEEDED. GET MEDICAL AID. NEVER GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS PERSON.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION AND VENTILATE AREA.
MOP SPILLS WITH INERT ABSORBENT. AVOID BREATHING VAPORS.
Waste Disposal Methods: IN ACCORDANCE W/APPLICABLE LOCAL, STATE AND FEDERAL
REGULATIONS. DO NOT PUNCTURE/INCINERATE/STORE ABOVE 120F. EXPOSURE TO
HEAT/PROLONGED EXPOSURE TO SUN: CONTAINER MAY BURST. DISCARD EMPTY IN TRASH
PI CK-UP. DO NOT PLACE IN HOME TRASH COMPACTOR.
Handling And Storage Precautions: KEEP OUT OF REACH OF CHILDREN.
CAUTION-CONTENTS UNDER PRESSURE. DO NOT STORE WHERE TEMPS MAY EXCEED 120F.
AVOID BREATHING SPRAY/MIST/VAPOR.
Other Precautions: AVOID CONTACT WITH EYES AND SKIN. USE WITH GOOD VENTILATION.
READ ENTIRE LABEL BEFORE REUSE. FOLLOW ALL LABEL DIRECTIONS. INTENTIONAL
MISUSE BY DELIBERATELY CONCENTRATING AND INHALING OR SWALLOWING CO NTENTS MAY
BE HARMFUL OR FATAL.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NR
Autoignition Temp Text: 874 F
Lower Limits: 1.8
Upper Limits: 9.5
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, SAND, WATER SPRAY.
Fire Fighting Procedures: WATER INEFFECTIVE/USED TO COOL CONTAINERS. WEAR
SELF-CONTAINED BREATHING APPARATUS. USE SHIELDING TO PROTECT PERSONNEL FROM
BURST/RUPTURE/VENT OF CONTAINERS.
Unusual Fire/Explosion Hazard: DO NOT SPRAY NEAR OPEN FLAME. AT ELEVATED
TEMPERATURE (OVER 120F) CONTAINERS MAY VENT/RUPTURE/BURST. AEROSOL
CONTAINERS; DO NOT EXPOSE TO TEMPS ABOVE 120F.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE BELOW TLV. USE NIOSH/MSHA APPROVED MASK ABOVE TLV.
Ventilation: LOCAL EXHAUST: PREFERRED. MECHANICAL: ACCEPTABLE AT POINT OF MIST
OR SPRAY RELEASE.
Other Protective Equipment: IMPERVIOUS CLOTHES TO PROTECT SKIN. EYE WASH
STATION.
Work Hygienic Practices: USE GOOD PERSONAL HYGIENE. DO NOT EAT, DRINK, OR SMOKE
WHILE USING PRODUCT.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: V3
Vapor Pres: 60 @ 65 F
Vapor Density: >1.5
Spec Gravity: .907 (WATER=1)
Solubility in Water: INSOLUBLE
Appearance and Odor: BLACK/PAINT
Percent Volatiles by Volume: 87
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: EXTREME HEAT.
Hazardous Decomposition Products: CARBON MONOXIDE, AND POSSIBLE HYDROGEN
CHLORIDE.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 77751
Product ID: SO SURE FLAT BLACK 37038 (14-390)
Review Date: 09/08/1992
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: PT
Container QTY: 0
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: DTJ
Symbols: D
DOT Proper Shipping Name: CONSUMER COMMODITY
Hazard Class: ORM-D
Label: NONE
Non Bulk Pack: 156,306
Bulk Pack: NONE
Max Qty Pass: 30KGGROSS
Max Qty Cargo: 30KGGROSS
Vessel Stow Req: A
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: AKH
IMO Proper Shipping Name: AEROSOLS/AEROSOL PRODUCT ?
IMDG Page Number: SEE 9022
UN Number: 1950
UN Hazard Class: 9?
IMO Packaging Group: -
Subsidiary Risk Label: -
EMS Number: 2-13
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ALS
IATA UN ID Num: 1950
IATA Proper Shipping Name: AEROSOLS, FLAMMABLE
IATA PSN Modifier: (EACH NOT EXCEEDING 1 L CAPACITY)
IATA UN Class: 2.1
IATA Label: FLAMMABLE GAS
Packing Note Passenger: 203
Max Quant Pass: 75KG
Max Quant Cargo: 150KG
Packaging Note Cargo: 203
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ALS
AFI Proper Shipping Name: AEROSOLS, NONFLAMMABLE, N.O.S.
AFI PSN Modifier: CONTAINING SUBSTANCES IN CLASS 8, PACKING GROUP I OR II
AFI Hazard Class: FORB
Back Pack Reference: FORBIDDEN
=======================================================
HAZCOM Label
=======================================================
Product ID: SO SURE FLAT BLACK 37038 (14-390)
Cage: 0FTT5
Company Name: LHB INDUSTRIES
Street: 8833 FLEISCHER PLACE
Zipcode: 63134
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: CONCENTRATING/INHALING CONTENTS HARMFUL/FATAL. REPORTS
ASSOCIATE REPEATED/PROLONGED OCCUPATIONAL OVEREXPOSURE W/PERMANENT
BRAIN/NERVOUS SYSTEM DAMAGE. CONFINED AREAS/HIGH CONCENTRATIONS ARE
ANESTHETIC . IRRITATION TO SKIN/RESPIRATORY TRACT.HARMFUL IF SWALLOWED.
SEVERE EYE IRRITATION. IRRITATION TO EYES,
THROAT, AND RESPIRATORY TRACT. MAY CAUSE HEADACHES, NAUSEA, A ND VOMITING.
OVEREXPOSURE MAY RESULT IN LIGHT HEADEDNESS, STAGGER, GIDDINESS, AND POSSIBLE
NAUSEA.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:830 9031 EKTACOLOR RA BLEACH FIX & REPLENISHER, WORK SOLN
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 85-90%
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMMONIUM THIOSULFATE
CAS:7783-18-8
RTECS #:XN6465000
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:FERRIC AMMONIUM ETHYLENEDIAMINETETRAACETIC ACID
CAS:21265-50-9
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM BISULFITE (SASA III) (CERCLA)
CAS:7631-90-5
RTECS #:VZ2000000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETIC ACID (CERCLA)
CAS:64-19-7
RTECS #:AF1225000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 PPM
ACGIH TLV:10 PPM/15 STEL; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:AMMONIUM SULFITE (CERCLA)
CAS:10196-04-0
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:EXPECTED TO BE LOW HAZ FOR
RECOMMENDED HNDLG.IN CONTACT W/STRONG ACIDS/IF HEATED,SULFITES MAY
LIBERATE SULFUR DIOXIDE GASE WHICH IRRIT TO RESP TRACT.SOME
ASTHMATICS OR HYPERSENSITIVE INDIVIDUALS MAY EXPERIENCE DIFFICULT
BREATHING.EYE:NO SPECIFIC HAZ KNOWN.MAY CAUSE TRANSIENT
IRRIT.SKIN:MATL HAS LOW POT (SIGN/SYM)
Explanation of Carcinogenicity:PER MSDS:CARCINOGENICITY
CLASSIFICATION:IARC/ACGIH/NTP/OSHA:NONE.
Effects of Overexposure:HEALTH:TO CAUSE ALLERGIC SKIN RX;HOWEVER CASES
OF HUMAN SKIN SENSITIZATION HAVE BEEN REPORTED.INGEST:MAY BE
HARMFUL IF SWALLOWED.SOME ASTHMATICS OR SULFITE-SENSITIVE
INDIVIDUALS MAY EXPERIENCE WHEEZIN G,CHEST TIGHTNESS,STOMACH
UPSET,HIVES,FAINTNESS,WEAKNESS,DIARRHEA.MAY CAUSE IRRIT OF
GASTROINTESTINAL TRACT.
Medical Cond Aggravated by Exposure:SOME ASTHMATICS OR HYPERSENSITIVE
OR SUFLITE-SENSITIVE INDIVIDUALS MAY EXPERIENCE DIFFICULT IN
BREATHING,WHEEZING,CHEST TIGHTNESS,STOMACH
UPSET,HIVES,FAINTNESS,WEAKNESS,DIARRHEA.
======================= First Aid Measures =======================
First Aid:INHAL:IF SYMPTOMATIC MOVE TO FRESH AIR.TREAT
SYMPTOMATICALLY.GET MED ATTN IF SYMPTOMS PERSIST.EYES:ANY MATL THAT
CONTACTS EYE SHOULD BE WASHED OUT IMMED W/WATER.SYMPTOMS OCCUR GET
MED ATTN.SKIN:WASH W /SOAP & WATER.GET MED ATTN IF SYMPTOMS
OCCUR.INGEST:DRINK 1-2 GLASSES OF WATER.SEEK MED ATTN.NEVER GIVE
ANYTHING BY MOUTH TO UNCONSC PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:NP
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE (CO2), DRY CHEMICAL,
ALCOHOL FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER W/LG AMTS OF WATER.OTHERWISE
ABSORB W/VERMICULITE OR OTHER INERT MATERIAL, THEN PLACE IN
CONTAINER FOR CHEMICAL WASTE. CLEAN SURFACE THOROUGHLY TO REMOVE
RESIDUAL CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATH MIST/VAP.AVOID CONTACT
W/EYE,PROL/REP CONTACT W/SKIN.USE W/ADEQU VENTI.KEEP FRM CONTACT
W/OXIDIZING AMTLS.KEEP CNTNR TIGHTLY CLSD.
Other Precautions:KEEP AWAY FRM INCOMPATIBLE SUBSTANCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.FULL-FACE
POSITIVE-PRESSURE AIR-SUPPL RESP MUST BE WORN IF HAZ DECOMPO PRODS
LIKELY TO BE RELEASED OR HAVE BEEN RELEASED.SEE
STABILITY/REACTIVITY SEC.RESP USED INSTITUTE PROGRAM TO ASSURE
COMPLIANCE W/29CFR1910.134.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES/HR)
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:EYEBATH, WASHING FACILITIES.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.GOOD INDUSTRIAL
HYGIENE PRACTICE TO MIN SKIN/EYE CONTACT.
Supplemental Safety and Health
PH:5.3-5.5. 2-PART KIT,THIS PNIND FOR WORK SOLN,PNIND:H FOR PART
A,PNIND:J FOR PART B;HCC=KEY1=N1.TO MAKE 10 LITERS.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:NP
Decomp Temp:Decomp Text:NP
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.102
pH:SUPPLE
Viscosity:NP
Evaporation Rate & Reference:NP
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID, DARK REDDISH-BROWN COLOR, SLIGHT AMMONIA
ODOR
Percent Volatiles by Volume:70-75
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS, BASES, SODIUM HYPOCHLORITE
(BLEACH).
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:HAZ COMBUST PROD:CO,CO2,OXIDES OF
NITROGEN,OXIDES OF SULFUR.HAZ DECOMPO PROD:AMMONIA,CHLORAMINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE/TREATMENT/DISPOSAL MAY BE SUBJECT TO
NATIONAL/STATE/LOCAL LAWS.FLUSH TO SEWER W/LG AMTS OF WATER.CHEM
SUBJ TO REPORTING REQMTS OF SEC 313 TITLE III SARA/40CFR372:NONE.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:22-050-02, SIGNA-TEX ACRYLIC RAW UMBER, (SUPDAT)
Preparer's Name:STEVEN S RUGIS
CAGE:EO233
CAGE:EO233
CAGE:13177
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION:DIZZINESS, BREATHING
DIFFICULTY, HEADACHES & LOSS OF COORDINATION. EYE:SEVERE
IRRITATION, TEARING, REDNESS AND BLURRED VISION. SKIN:CAN DRY AND
DEFAT SKIN CAUSING CRACKS, IRRITATION, AND DERMATITIS.
INGESTION:CAN CAUSE GASTROINTESTINAL IRRITATION, VOMITING, NAUSEA,
& DIARRHEA.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE PERSON TO FRESH AIR. IF BRTHG STOPS, APPLY ARTF
RESP & SEEK IMMED MED ATTN. EYE:FLUSH W/LG QTYS OF WATER FOR @
LEAST 15 MINS. SKIN:WASH THORO W/SOAP & WATER & SEE A DOCTOR.
INGEST:DO NOT IN DUCE VOMIT, CAN CAUSE CHEM PNEUM & PULMONARY
EDEMA. CONTACT PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, ALCOHOL FOAM, CO*2, DRY CHEMICAL, WATER FOG,
OTHER.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER SHOULD NOT BE USED EXCEPT AS FOG TO KEEP NEARBY
CONTAINERS COOL.
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES, PROVIDE GOOD
VENTILATION, DIKE SPILL AREA AND ADD ABSORBENT EARTH OR SAWDUST TO
SPILLED LIQUID. THOROUGHLY WET W/WATER AND MIX.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE NON-SPK UTENSILS WHEN HANDLING
MATL. AVOID HOT METAL SURF. USE IN COOL, WELL-VENTILATED AREAS.
KEEP CNTNRS CLSD WHEN NOT IN USE.
Other Precautions:KEEP AWAY FROM EXCESS HEAT & OPEN FLAMES. SMKNG IN
AREA WHERE MATL IS USED SHOULD BE STRICTLY PROHIBITED. TOOLS USED
W/MATL SHOULD BE MADE FROM ALUMINUM, BRASS/COPPER. PLASTIC UTENSILS
SHOULD NOT BE U SED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN SPRAYING MATL USE NIOSH/MSHA APPRVD
CARTRIDGE RESP/GAS MASK SUITABLE TO KEEP AIRBORNE MISTS & VAP CONC
BELOW TIME WEIGHTED THRESHOLD LIM VALUES. WHEN USING IN POORLY
VENTILATED & CONFINED SPACES, USE NIOSH/MSHA APPRVD
SUPPLYING(SUPDAT)
Ventilation:GEN MECH VENT OR LOC EXHAUST SHOULD BE SUITABLE TO KEEP VAP
CONC BELOW TLV. VENT EQUIP MUST BE EXPLOSION PROOF.
Other Protective Equipment:IMPERMEABLE APRONS. USE OF HEAD CAPS
WHENEVER POSSIBLE IS STRONGLY RECOMMENDED.
Work Hygienic Practices:ANSI APPRVD EMERGENCY EYE WASH & DELUGE SHOWER
.
Supplemental Safety and Health
MFR TRADE NAME/PART NO:ARAWUMB. RESP PROT:RESPIRATOR OR NIOSH/MSHA
APPRVD SELF-CONTAINED BREATHING APPARATUS.
================== Physical/Chemical Properties ==================
Vapor Density:HVR/AIR
Spec Gravity:1.29 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SOLUBLE
Appearance and Odor:OPAQUE, VISCOUS LIQUID WITH AMMONIA ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALINE MATERIALS, STRONG ACIDS AND OXIDIZING MATERIALS.
Stability Condition to Avoid:EXCESSIVE HEAT, POOR VENTILATION,
CORROSIVE ATMOSPHERES, EXCESSIVE AGING.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN, AND POSSIBLY ACROLEIN.
==================== Disposal Considerations ====================
Waste Disposal Methods:COLLECT ABSORBENT/WATER/SPILLED LIQUID MIXTURE
INTO METAL CONTAINERS AND ADD ENOUGH WATER TO COVER. CONSULT LOCAL,
STATE & FEDERAL HAZARDOUS WASTE REG BEFORE DISPOSING INTO APPROVED
HAZARDOUS WASTE LA NDFILLS. OBEY RELEVANT LAWS.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: 16 BRICK SAND
Cage: GO456
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: GO456
Assigned Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: GO456
=======================================================
Ingredients
=======================================================
Cas: 14808-60-7
RTECS #: VV7330000
CARC IARC-GROUP 2A; SUSPECTED CARC NTP) *95-3*
Other REC Limits: 0.05 MG/CUM NIOSH
OSHA PEL: 0.1 MG/CUM RESP DUST
ACGIH TLV: 0.1 MG/CUM RESP DUST
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: INHALATION OF CRYSTALLINE SILICA DUST MAY CAUSE SILICOSIS,
A DISABLING, PROGRESSIVE & SOMETIMES FATAL PULMONARY FIBROSIS IN THE
LUNGS.
Explanation Of Carcinogenicity: SEE INGREDIENTS.
Signs And Symptions Of Overexposure: COUGH, SHORTNESS OF BREATH, CONGESTION,
CHEST PAIN/ILLNESSES
First Aid: INHALATION: MOVE AWAY TO FRESH AIR AT ONCE. IF BREATHING HAS
STOPPED, PERFORM ARTIFICIAL REPIRATION. EYES: WASH IMMEDIATELY W/LARGE
AMOUNTS OF WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: RESTRICT AREA FROM PERSONS NOT WEARING PROTECTIVE
EQUIPMENT & CLOTHING. VENTILATE AREA TO REDUCE DUST CONCENTRATION. CLEAN
UP BY RECOMMENDED DUSTLESS METHODS - WATER/VACUUM.
Waste Disposal Methods: SECURED SANITARY LANDFILL IN ACCORDANCE W/LOCAL, STATE
& FEDERAL REGULATIONS.
Handling And Storage Precautions: USE DUSTLESS SYSTEMS FOR HANDLING, STORAGE
& CLEAN-UP. VENTILATE WORK AREA, TEST FOR PRESENCE & CONCENTRATION OF
RESPERIABLE SILICA.
Other Precautions: MAINTAIN VENTILATION SYSTEM, POST WARNING TO EMPLOYEES WHERE
PRODUCT IS USED, STORED & HANDLED. REGULAR CHEST X-RAY & SPIROMETRY
ARE RECOMMENDED.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NON-COMBUSTIBLE
Fire Fighting Procedures: NO ACUTE HAZARD. AVOID BREATHING VAPORS/DUST.
Unusual Fire/Explosion Hazard: CONTACT W/POWERFUL OXIDIZING AGENTS MAY CAUSE
FIRES.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH/MSHA APPROVED RESPIRATORS IF EXPOSURE EXCEEDS
0.1 MG/CUM OVER AN 8 HOUR PERIOD.
Ventilation: LOCAL EXHAUST/GENERAL DILUTION TO MEET PELS.
Work Hygienic Practices: PRACTICE GOOD HOUSEKEEPING.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 4046F
M.P/F.P Text: 3100F
Vapor Pres: 760
Spec Gravity: 2.65
Solubility in Water: INSOLUBLE
Appearance and Odor: COLORLESS & ODORLESS
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE
Materials To Avoid: OXIDIZING AGENTS. SILICA IS ATTACKED BY HYDROFLUORIC ACID.
Hazardous Decomposition Products: NONE
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: 16 BRICK SAND
Cage: GO456
Assigned IND: Y
Company Name: HOLLIDAY SAND & GRAVEL CO
Street: 6811 W 63RD ST
Zipcode: 66202
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: INHALATION OF CRYSTALLINE SILICA DUST MAY CAUSE
SILICOSIS, A DISABLING, PROGRESSIVE & SOMETIMES FATAL PULMONARY FIBROSIS
IN THE LUNGS.
COUGH, SHORTNESS OF BREATH, CONGESTION, CHEST PAIN/ILLNESSES
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:21135 SODIUM CITRATE DIHYDRATE S279-10
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM CITRATE
CAS:6132-04-3
Fraction by Wt: 100%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MECHANICAL IRRITANT. SKIN: MAY
CAUSE IRRITATION. INGESTION: LARGE AMOUNTS MAY CAUSE
GASTROINTESTINAL IRRITATION. INHALATION: RESPIRATORY TRACT
IRRITANT. LOW HAZARD FOR USUAL INDUSTRIAL HANDLING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR 15 MINS. SKIN: FLUSH
W/PLENTY OF SOAP & WATER FOR 15 MINS. INGESTION: IF CONSCIOUS &
ALERT, GIVE 2-4 CUPFULS OF MILK/WATER. NEVER GIVE ANYTHING BY MOUTH
IF UNCONSCIOU S. INHALATION: REMOVE TO FRESH AIR IMMEDIATELY. GIVE
CPR/OXYGEN IF NECESSARY. OBTAIN MEDICAL ATTENTION IN ALL CASES.
NOTES TO PHYSICIAN: TREAT SYMPTOMATICALLY & SUPPORTIVELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CO2/CHEMICAL FOAM
Fire Fighting Procedures:USE APPROPRIATE PROTECTIVE CLOTHING TO PREVENT
CONTACT W/SKIN & EYES. USE SELF CONTAINED BREATHING APPARATUS TO
PREVENT CONTACT W/THERMAL DECOMPOSITION PRODUCTS
Unusual Fire/Explosion Hazard:DUSTS AT SUFFICIENT CONCENTRATIONS CAN
FORM EXPLOSIVE MIXTURES W/AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM/SWEEP UP MATERIAL & PLACE INTO A
SUITABLE DISPOSAL CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM CONTACT W/OXIDIZING
MATERIALS. USE W/ADEQUATE VENTILATION. WEAR APPROPRIATE PROTECTIVE
CLOTHING TO PREVENT SKIN EXPOSURE.
Other Precautions:AVOID CONTACT W/EYES, SKIN & CLOTHING. AVOID
INGESTION & INHALATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ALWAYS USE A NIOSH-APPROVED RESPIRATOR WHEN
NECESSARY. FOLLOW OSHA RESPIRATOR REGULATIONS.
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT TO CONTROL
AIRBORNE LEVELS.
Other Protective Equipment:PROTECTIVE CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
PH IS FOR 5% SOLUTION.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:597F
Spec Gravity:1.665
pH:7-9
Solubility in Water:COMPLETE
Appearance and Odor:WHITE CRYSTALLINE SOLID; ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:BUFFER PH 4.00, RED, 34170-172
CAGE:38445
CAGE:38445
============= Composition/Information on Ingredients =============
Ingred Name:2-BIPHENYLOL, SODIUM SALT; (DOWICIDE A). LD50:(ORAL,RAT)
656 MG/KG
CAS:132-27-4
RTECS #:DV7700000
Fraction by Wt: 0.05%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POTASSIUM ACID PHTHALATE
CAS:877-24-7
Fraction by Wt: 1.02%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:2,7-NAPHTHALENEDISULFONIC ACID,
3-HYDROXY-4-((4-SULFO-1-NAPHTHYL)AZO)-, TRISODIUM SALT; (AMARANTH)
CAS:915-67-3
RTECS #:QJ6550000
Fraction by Wt: 0.0028%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE & CHRONIC:NONE SPECIFIED BY
MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE IDENTIFIED.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/PLENTY OF WATER FOR @ LEAST 15 MINS WHILE HOLDING
EYELIDS OPEN. HAVE EYES EXAMINED BY MED PERS. SKIN:WASH W/SOAP &
WATER. GET MED ATTN IF IRRIT DEVELOPS/PERSISTS. INGEST:DO NOT
INDUCE VOMI T. GIVE VICTIM GLASS OF WATER/MILK. CALL PHYS IMMED.
NEVER GIVE ANYTHING BY MOUTH TO UNCON PERSON. INHAL:REMOVE TO FRESH
AIR.
===================== Fire Fighting Measures =====================
Extinguishing Media:NONCOMBUSTIBLE. USE ANY SUITABLE FOR ADJACENT
MATERIAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:EVAC AREA OF ALL UNNECESSARY PERS. WEAR
SUITABLE PROT EQUIP LISTED IN EXPOSURE CONTROLS/PERSONAL PROT. CNTN
RELEASE & ELIM IT'S SOURCES, IF THIS CAN BE DONE W/OUT RISK. TAKE
UP & CONTAINERIZE FOR PROP ER DISP AS DESCRIBED UNDER DISPOSAL.
(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN ACCORDANCE WITH GOOD
LABORATORY INDUSTRIAL HYGIENE AND SAFETY PRACTICES.
Other Precautions:ENGINEERING CONTROLS:ENGINEERING AND/OR
ADMINISTRATIVE CONTROLS SHOULD BE IMPLEMENTED TO REDUCE EXPOSURE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SPECIFIED. NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPILL RELEASE:COMPLY W/FEDERAL, STATE, AND LOCAL REGS ON RPTG RELEASES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Spec Gravity:1
pH:4
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR, RED LIQUID, ODORLESS
Percent Volatiles by Volume:99
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS.
Stability Condition to Avoid:HEAT.
Hazardous Decomposition Products:CO*X.
==================== Disposal Considerations ====================
Waste Disposal Methods:EPA WASTE NUMBER(S):THIS MATERIAL DOES NOT HAVE
AN EPA WASTE NUMBER. ALWAYS CONTACT A PERMITTED WASTE (TSD) TO
ASSURE COMPLIANCE WITH ALL CURRENT LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:340HS NO. 11136 PC 834G104
Kit Part:Y
Preparer's Name:SEROJE HARTOONIANI
CAGE:83574
CAGE:85570
CAGE:83574
============= Composition/Information on Ingredients =============
Ingred Name:METHYL N-AMYL KETONE (VAPOR PRESSURE 2.1 MM HG)
CAS:110-43-0
RTECS #:MJ5075000
Fraction by Wt: 15%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:50 PPM
Ingred Name:METHYL PROPYL KETONE (VAPOR PRESSURE 27.8 MM HG)
CAS:107-87-9
RTECS #:SA7875000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/STEL 250 PPM
ACGIH TLV:200 PPM/STEL 250 PPM
Ingred Name:BUTYL ACETATE (VAPOR PRESSURE 8.4 MM HG)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM/STEL 200 PPM
ACGIH TLV:150 PPM/STEL 200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:NON-HAZARDOUS ADDITIVES, RESIN AND PIGMENTS (VAPOR PRESSURE
0 MM HG)
Fraction by Wt: 30%
Other REC Limits:NONE SPECIFIED
Ingred Name:POLYESTER RESIN (VAPOR PRESSURE 0 MM HG)
CAS:85959-88-2
Fraction by Wt: 15%
Other REC Limits:NONE SPECIFIED
Ingred Name:TOLUENE (SARA III) (VAPOR PRESSURE 22 MM HG)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE (SARA III) (VAPOR PRESSURE 10 MM HG)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/STEL 150 PPM
ACGIH TLV:100 PPM/STEL 150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TITANIUM DIOXIDE (VAPOR PRESSURE 0 MM HG) (FULLY
ENCAPSULATED FORM NOT NORMALLY HAZARDOUS UNLESS SANDED OR GROUND)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:BARIUM SULFATE (SARA III) (VAPOR PRESSURE 0 MM HG)
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: 15%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:CRYSTALLINE SILICA - QUARTZ (VAPOR PRESSURE 0 MM HG)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:AROMATIC SOLVENT (VAPOR PRESSURE 5.2 MM HG)
CAS:64742-94-5
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
Ingred Name:ACETYLACETONE (VAPOR PRESSURE 7 MM HG)
CAS:123-54-6
RTECS #:SA1925000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
Ingred Name:VOC G/L: 340 WITH 930G052 @ 3/1
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:UNKNOWN IARC:YES
Health Hazards Acute and Chronic:ACUTE; INHALE: NASAL & RESP
IRRITATION, ACUTE CENTRAL NERVOUS SYSTEM DEPRESSN (HEADACHE,
DIZZINESS, STAGGERING, CONFUSION, UNCONSCIOUSNESS). ASPHYXIATION
(BREATHING OXYGEN DEFICIENT AIR). EYE: IRRIT. INGEST: GI
IRRITATION, NAUSEA, VOMITING, DIARRHEA. ASPIRATION INTO LUNGS CAN
CAUSE CHEM PNEUMONITIS WHICH CAN BE FATAL.
Explanation of Carcinogenicity:CRYSTALLINE SILICA HAS BEEN CLASSIFIED
BY IARC AS PROBABLY CARCINOGENIC TO HUMANS.
Effects of Overexposure:CHRONIC: SKIN: IRRIT, DEFATTING, DERMATITIS.
PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE (CONCENTRATION
DIFFICULTIES, DIMINISHED DEXTERITY & MEMORY LOSS). SILICOSIS.
ANIMAL STUDIES: LUNG TUMORS, LIVER, KIDNEY, LUNG, SPLEEN, HEART,
ADRENAL DAMAGE. RATS & MICE EXPOSED DURING PREGNANCY SHOW
EMBRYO/FETOTOXIC EFFECTS.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN, LUNG AND EYE
CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE ARTIFICIAL RESPIRATION
OR CPR IF REQUIRED. IF BREATHING DIFFICULT, GIVE OXYGEN. KEEP WARM
& QUIET. GET MED AID. SKIN: WASH AFFECTED AREAS WITH SOAP & WATER.
DONT USE SOLVENTS. REMOVE CONTAMINATED CLOTHING & WASH BEFORE
REUSE. GET MEDICAL AID. EYE: FLUSH W/WATER FOR 15 MINUTES. GET MED
ATTENTION, PREFERRABLY AN OPHTHALMOLOGIST. INGESTION: GET MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:80.0F,26.7C
Autoignition Temp:Autoignition Temp Text:991 F
Lower Limits:1
Extinguishing Media:EXTINGUISHERS (CARBON DIOXIDE, DRY CHEMICAL OR
FOAM).
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE, USE TO COOL FIRE
EXPOSED CONTAINERS (FOG NOZZLES PREFERRED). WEAR NIOSH/MSHA SCBA &
PROTECTIVE CLOTHES TO PREVENT SKIN & EYE CONTACT.
Unusual Fire/Explosion Hazard:VAPORS COLLECT IN INADEQUATELY VENTED/
CONFINED AREAS, FORM EXPLOSIVE MIX W/AIR, TRAVEL LONG DISTANCE,
FLASHBACK TO HANDLING SITE. CLSD CNTNR MAY EXPLODE W/HEAT
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR AIR SUPPLIED RESPIRATOR FOR MAJOR
UNVENTED SPILL. COVER WITH ABSORBENT. SCOOP INTO CONTAINERS.
CLEAN-UP RESIDUE WITH SUITABLE SOLVENT. DISPOSE OF SPILLAGE IN
COMPLIANCE WITH FEDERAL & STATE REGUL ATIONS. ULTIMATE DISPOSAL
METHOD-INCINERATION.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNR CLOSED. KEEP FROM HEAT,
ELECTRICAL EQUIP, SPARK & FLAME. DONT STORE ABOVE 49 C. STORE FLAMM
LIQ IN ACCORD W/NFPA CODES & GOVERNMENTAL REGS.
Other Precautions:FOLLOW GROUND/BOND PROCEDURES WHEN TRANSFERRING.
AVOID FREE FALL OF LIQUID. DONT SMOKE NEAR MAT'L. DONT APPLY TO HOT
SURFACES. EMPTY DRUMS CONTAIN EXPLOSIVE VAPOR. DONT CUT, PUNCTURE,
WELD ON/NEAR DRU M. DONT INGEST. OBSERVE LABEL WARNINGS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AIR SUPPLIED RESPIRATOR OR ORGANIC VAPOR/ACID
GAS/DUST/FUME/MIST CARTRIDGE.
Ventilation:IF EMPLOYEES PRESENT, GENERAL DILUTION/LOCAL EXHAUST TO
KEEP BELOW TLV. WHERE NO EMPLOYEES, KEEP BELOW 25% OF LEL.
Other Protective Equipment:AVOID SKIN CONTACT BY USE OF PROTECTIVE
CLOTHING. SAFETY SHOWER, EYE BATH & WASHING FACILITIES SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F5
Boiling Pt:B.P. Text:213 TO 354F
Vapor Density:> AIR
Spec Gravity:1.19
Viscosity:>30SEC FORD#4
Evaporation Rate & Reference:SLOWER THAN N-BU AC
Solubility in Water:SLIGHT
Appearance and Odor:RED LIQUID, SOLVENT ODOR
Percent Volatiles by Volume:49.98
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION ARE HAZARDOUS
INCLUDING CARBON MONOXIDE AND CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WHEN DISPOSING OF MAT'L, ENSURE THAT IT'S
PACKAGED, STORED, TRANSPORTED, ETC IN ACCORD W/LOCAL, STATE, & FED
REGS. USE NO DISPOSAL METHOD THAT WOULD POSE ENVIRONMENTAL OR HUMAN
HEALTH THREAT INCLUDING CONTAMINATE GROUND/SURFACE WATER.
IGNITABLE LIQ.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: RM 710EP 6-TEMP EPOXY MORTAR PART C
Kit Part: Y
Cage: EO264
Box: 21148
=======================================================
Contractor Summary
=======================================================
Cage: 11239
Box: 21148
Cage: EO264
Box: 21148
=======================================================
Ingredients
=======================================================
Cas: 14808-60-7
RTECS #: VV7330000
OSHA PEL: 0.1 MG/M3 (MFR)
ACGIH TLV: 0.1 MG/M3 RDUST
------------------------------
RTECS #: 9999999VO
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: NONE EXPECTED FROM NORMAL USE OF THIS PRODUCT. EXCESS
EXPOSURE TO DUSTS BY INHALATION FOR EXTENDED PERIODS OF TIME CAN LEAD TO
DEVELOPMENT OF PULMONARY DISEASES INCLUDING PNEUMOCONIOSIS SUCH AS SILICO
SIS. EYES:MECHANICAL INJURY CAN OCCUR FROM RUBBING EYES DUE TO ABRASIVE
NATURE OF SAND. SKIN:PROLONGED (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: SILICA, CRYSTALLINE-QUARTZ:IARC MONOGRAPHS,
SUPP, VOL 7, PG 341, 1987:GRP 2A. NTP 7TH ANNUAL RPT ON CARCINS, (SUPP DATA)
Signs And Symptions Of Overexposure: HLTH HAZ:& REPEATED EXPOSURE TO THE
HANDS CAN LEAD TO DRYING OF SKIN & DERMATITIS. INHALATION:EXCESSIVE
EXPOSURE TO DUSTS CAN LEAD TO BREATHING DIFFICULTY.
Medical Cond Aggravated By Exposure: EYE, SKIN & RESPIRATORY CONDITIONS.
First Aid: EYES:IMMEDIATELY FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINUTES.
CALL MD IF IRRITATION PERSISTS. SKIN:WASH W/SOAP & WATER. INHAL:MOVE
VICTIM TO FRESH AIR. CALL MD IF SYMPTOMS PERSIST. INGEST:GIVE PLE NTY OF
WATER TO DRINK. SEEK MED ATTENTION. DO NOT INDUCE VOMITING UNLESS DIRECTED TO
BY MD. OTHER:REFERRAL TO MD IS RECOMMENDED IF THERE IS ANY QUESTION ABOUT THE
SERIOUSNESS OF THE INJURY/EXPOSURE.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SWEEP UP & DISCARD.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: CONSULT W/REGULATORY AGENCIES OR CORPORATE PERSONNEL
FOR DISPOSAL METHODS THAT COMPLY W/LOCAL, STATE & FEDERAL HEALTH &
ENVIRONMENTAL REGULATIONS.
Handling And Storage Precautions: AVOID CONTACT W/EYES, SKIN OR CLOTHING. STORE
IN A DRY LOCATITION.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: MEDIA SUITABLE FOR SURROUNDING FIRE (FP N).
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE KNOWN.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE NORMALLY REQD W/ADEQ VENT AS NOTED. USE NIOSH
APPROVED DUST MASK WHEN WORKING IN AREAS WHERE DUST IS BEING GENERATED ABOVE
THE PEL/TLV. WEARING NIOSH APPROVED DUST MASK IN ANY DUSTY SITUATION WIL L
REDUCE POTNTL FOR EXPOS TO SILICA.
Ventilation: GENERAL, I.E. NATURAL OR MECHANICALLY INDUCED FRESH AIR MOVEMENTS.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: WASH HANDS AFTER HANDLING.
Supplemental Safety and Health: MATLS TO AVOID:TRIOXIDE, OXYGEN TRIFLUORIDE.
EXPLAN OF CARCIN:1994:ANTICIPATED TO BE CARCINOGEN.
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 2.6
Solubility in Water: NIL
Appearance and Odor: WHITE OR TAN SAND GRANULES, CRUSHED OR GROUND; NO ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: STRONG OXIDIZING AGENTS. CONT W/POWERFUL OXIDIZING AGENTS
SUCH AS FLUORINE, CHLORINE TRIFLUORIDE, MANGANESE (SUPP DATA)
Hazardous Decomposition Products: NONE EXPECTED.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: RM 710EP 6-TEMP EPOXY MORTAR PART C
Cage: EO264
Assigned IND: Y
Company Name: HILTI INC
Street: 5400 S 122ND EAST AVE
PO Box: 21148
Zipcode: 74121
Label Required IND: Y
Date Of Label Review: 12/03/1996
Status Code: C
Label Date: 12/03/1996
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE:NONE EXPECTED FROM NORMAL USE OF THIS PRODUCT.
EYES:MECHANICAL INJURY CAN OCCUR FROM RUBBING EYES DUE TO ABRASIVE NATURE OF
SAND. SKIN:PROLONGED AND REPEATED EXPOSURE CAN LEAD TO DRYING OF SKIN AND
DERMATITIS. INHALATION:EXCESSIVE EXPOSURE TO DUSTS CAN LEAD TO BREATHING
DIFFICULTY. CHRONIC:CANCER HAZARD. CRYSTALLINE, SILICA QUARTZ IS LISTED AS AN
ANIMAL LUNG CARCINOGEN (FP N). EXCESS EXPOSUR E TO DUSTS BY INHALATION FOR
EXTENDED PERIODS OF TIME CAN LEAD TO DEVELOPMENT OF PULMONARY DISEASES
INCLUDING PNEUMOCONIOSIS SUCH AS SILICOSIS.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SILICA GEL,SYNTHETIC AMORPHOUS SILICA,SIO2.
CAGE:00334
CAGE:60777
CAGE:NO742
CAGE:00334
============= Composition/Information on Ingredients =============
Ingred Name:SILICA GEL
CAS:63231-67-4
RTECS #:VV7322000
Fraction by Wt: 95-100%
Other REC Limits:NONE SPECIFIED
OSHA PEL:80 MG/M3 / % SIO2
ACGIH TLV:10 MG/M3
Ingred Name:NON HAZARDOUS INGREDIENTS
Fraction by Wt: 0-5%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS EST. >31,600 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT IS DRYING TO BODY TISSUES AND
MECHANICALLY IRRITATING. AS WITH ANY DUST, CHRONIC INHALATION OF
THE DUST MAY LEAD TO SILICOSIS OR OTHER CHRONIC RESPIRATORY
PROBLEMS.
Explanation of Carcinogenicity:THIS PRODUCT AND ITS COMPONENTS ARE NOT
LISTED ON THE IARC, NTP OR OSHA CARCINOGENS LISTS.
Effects of Overexposure:EYE:MECHANICAL IRRITATION.
SKIN:DRYING,IRRITATION. INHALED:RESPIRATORY IRRITATION, COUGHING.
INGESTED:POSSIBLE G/I IRRITATION.
Medical Cond Aggravated by Exposure:MANUFACTURER KNOWS OF NO MEDICAL
CONDITIONS ABNORMALLY AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY WASH FROM EYES WITH LARGE AMOUNTS OF WATER,
OCCASIONALLY LIFTING THE UPPER & LOWER EYE LIDS. IF IRRITATION
OCCURS AND PERSISTS, SEEK MEDICAL ATTENTION. SKIN: WASH WITH SOAP
AND WATER . INHALATION:REMOVE TO FRESH AIR. INGESTION: MATERIAL
WILL PASS THROUGH THE BODY NORMALLY. IF ANY IRRITATION PERSISTS,OR
IS SEVERE,SEE A DOCTOR.
===================== Fire Fighting Measures =====================
Extinguishing Media:PRODUCT IS NON FLAMMABLE. EXTINGUISH FIRE WITH
MEDIA APPROPRIATE FOR SOURCE OF FIRE.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP OR VACUUM UP OR FLUSH TO SEWER. AVOID
CREATING DUST DURING CLEAN UP.
Neutralizing Agent:NONE REQUIRED
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A DRY AREA. KEEP TIGHTLY
CLOSED AND PROTECTED FROM MOISTURE TO PROTECT QUALITY.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR WILL NOT NORMALLY BE NECESSARY. USE
NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR OR RESPIRATOR FOR DUST
IF EXPOSURE IS ABOVE THE TLV/PEL. SEE 29 CFR 1910.134 FOR
REGULATIONS PERTAINING TO R ESPIRATOR USE.
Ventilation:NORMAL ROOM VENTILATION IS USUALLY ADEQUATE TO MAINTAIN
DUST LEVELS BELOW PEL/TLV FOR NUISANCE DUST.
Other Protective Equipment:LONG SLEEVED WORK CLOTHING.
Work Hygienic Practices:USE GOOD PERSONAL HYGIENE PRACTICE. VACUUM UP
ANY DUST. LAUNDER CLOTHING BEFORE REUSE.
Supplemental Safety and Health
SILICA GEL IS A SYNTHETIC AMORPHOUS SILICA NOT TO BE CONFUSED WITH
CRYSTALLINE SILICA. EPIDEMIOLOGICAL STUDIES INDICATE LOW POTENTIAL
FOR ADVERSE HEALTH EFFECTS. SILICA GEL IS CONSIDERED TO BE A NUISA
NCE DUST. IN THE ACTIVATED FORM, SILICAGEL ACTS AS A DESICCANT &
CAN CAUSE A DRYING IRRITATION OF THE MUCOUS MEMBRANES.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:>2900F
Spec Gravity:40 LB/CU.FT
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE GRANULES; OLORLESS
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN AN APPROVED LANDFILL ACCORDING TO
LOCAL, STATE AND FEDERAL REGULATIONS. COVER PROMPTLY TO AVOID
BLOWING DUST.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:LEAD ACID BATTERY
CAGE:60038
CAGE:0FGN2
CAGE:20038
CAGE:60038
============= Composition/Information on Ingredients =============
Ingred Name:SULFURIC ACID (SARA III)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 10-30%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:LEAD (SARA III)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 60%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.05 MG/M3;1910.1025
ACGIH TLV:0.15 MG/M3;DUST 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ANTIMONY (SARA III)
CAS:7440-36-0
RTECS #:CC4025000
Fraction by Wt: 2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.5 MG/M3
ACGIH TLV:0.5 MG SB/M3; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ARSENIC (SARA III)
CAS:7440-38-2
RTECS #:CG0525000
Fraction by Wt: 0.2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.5 MG/M3 (AS)
ACGIH TLV:0.01,A1 MG/M3; 9394
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CALCIUM, METAL
CAS:7440-70-2
RTECS #:EV8040000
Fraction by Wt: 0.2%
Other REC Limits:NONE SPECIFIED
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
Fraction by Wt: 0.2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9192
Ingred Name:POLYPROPYLENE
CAS:9003-07-4
RTECS #:UD1842000
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
Ingred Name:POLYSTYRENE
CAS:9003-53-6
RTECS #:WL6475000
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
Ingred Name:STYRENE ACRYLONITRILE
CAS:9003-54-7
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
Ingred Name:ACRYLONITRILE BUTADIENE STYRENE
CAS:9003-56-9
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
Ingred Name:STYRENE BUTADIENE
CAS:9003-55-8
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
Ingred Name:POLYVINYLCHLORIDE
CAS:9002-86-2
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
Ingred Name:POLYCARBONATE
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
Ingred Name:HARD RUBBER
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: BURNS, SEVERE IRRITATION OF
SKIN, EYES, MOUTH, THROAT, ESOPHAGUS AND STOMACH; INFLAMMATION OF
BRONCHIAL MEMBRANES. CHRONIC: EROSION OF TEETH, INFLAMMATION OF
NOSE, THROAT AND BRONCHIAL TUBES.
Explanation of Carcinogenicity:LEAD IS LISTED BY IARC AND NTP. ARSENIC
IS LISTED BY IARC, NTP AND OSHA.
Effects of Overexposure:COUGH, INCREASED RESPIRATORY RATE, STINGING,
BURNING SENSATION ON SKIN, EYE IRRITATION, DISCOLORATION OF TEETH.
Medical Cond Aggravated by Exposure:EXPOSURE TO MISTS MAY CAUSE LUNG
DAMAGE AND AGGRAVATE PULMONARY CONDITIONS. CONTACT WITH SKIN MAY
AGGRAVATE SKIN DISEASES SUCH AS ECZEMA AND CONTACT DERMATITIS.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH WITH PLENTY OF WATER. SEE DOCTOR
IMMEDIATELY. REMOVE CONTAMINATED CLOTHING AND SHOES. INHALATION:
REMOVE TO FRESH AIR. GIVE OXYGEN/CPR IF NEEDED. SEE DOCTOR.
INGESTION: DO NOT INDUCE VOMITING. GIVE MILK OR WATER, FOLLOWED BY
2 OUNCES OF MILK OF MAGNESIA (NO CARBONATES). SEE DOCTOR
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:4.1(HYDROGN)
Upper Limits:74(HYDROGEN)
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL, HALOGEN.
Fire Fighting Procedures:IF BATTERIES ARE ON CHARGE, SHUT OFF POWER.
USE POSITIVE PRESSURE SCBA. WATER APPLIED TO ACID GENERATES HEAT
AND CAUSES SPATTER. WEAR ACID-RESISTANT CLOTHING.
Unusual Fire/Explosion Hazard:FLAMMABLE AND EXPLOSIVE HYDROGEN GAS IS
PRODUCED DURING CHARGING AND OPERATION. REMOVE ALL IGNITION
SOURCES. VENTILATE AREA.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR APPROPIATE PROTECTIVE EQUIPMENT. DILUTE
CAUTIOUSLY WITH WATER. COVER WITH SODA ASH OR QUICKLIME. SCOOP UP
AND PLACE IN APPROPIATE DISPOSAL CONTAINER. FLUSH AREA WITH LARGE
AMOUNTS OF WATER.
Neutralizing Agent:SODA ASH (SODIUM CARBONATE), BAKING SODA OR
QUICKLIME (CALCIUM OXIDE).
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE. STORE AWAY
FROM FLAMES, IGNITION SOURCES, COMBUSTIBLE AND ORGANIC MATERIALS.
AVOID PROLONGED OVERCHARGING.
Other Precautions:DO NOT CARRY BATTERY BY TERMINALS. DO NOT DROP
BATTERY, PUNCTURE OR ATTEMPT TO OPEN BATTERY CASE. KEEP TERMINALS
COVERED IN PLASTIC CASE. AVOID SHORTING BATTERIES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. NIOSH/MSHA-APPROVED
CARTRIDGE RESPIRATOR FOR ACIDS OR FULL FACE MASK AS APPROPIATE FOR
EXPOSURE OF CONCERN WHEN TLV IS EXCEEDED.
Ventilation:GENERAL (MECHANICAL) VENTILATION. LOCAL EXHAUST IN CONFINED
AREAS. USE ACID RESISTANT COMPONENTS.
Other Protective Equipment:RUBBER APRON AND BOOTS IF CONTACT IS
EXPECTED. EYE WASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
THIS MSDS WAS PREPARED FOR SULFURIC ACID EXPOSURE. HAZARDOUS EXPOSURE
TO LEAD COMPOUNDS CAN OCCUR ONLY WHEN PRODUCT IS HEATED, OXIDIZED
OR OTHERWISE PROCESSED OR DAMAGED TO CREATE DUST, VAPOR OR FUME.
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:=95.C, 203.F
Vapor Pres:10
Vapor Density:>1
Spec Gravity:1.23-1.35
pH:ACIDIC
Evaporation Rate & Reference:<1 (BUTYL ACETATE = 1)
Solubility in Water:COMPLETE
Appearance and Odor:ACID IN BATTERY IS CLEAR LIQUID WITH SHARP,
PENETRATING, PUNGENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
COMBUSTIBLES, ORGANIC MATERIAL, STRONG REDUCING AGENTS, METALS, SULFUR
TRIOXIDE GAS, STRONG OXIDIZERS, WATER.
Stability Condition to Avoid:AVOID SHORTING, USE ONLY APPROVED CHARGING
METHODS. AVOID OVERCHARGING AND SOURCES OF IGNITION.
Hazardous Decomposition Products:SULFURIC ACID FUMES, SULFUR DIOXIDE,
SULFUR TRIOXIDE, CARBON MONOXIDE, HYDROGEN GAS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGUALTIONS. SPEND BATTERIES: SEND TO SECONDARY LEAD
SMELTER FOR RECYCLING.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:LOW TEMPERATURE MODIFIED POLYESTER
CAGE:4H281
CAGE:4H281
============= Composition/Information on Ingredients =============
Ingred Name:VM&P NAPHTHA (LIGROINE)
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 25%
OSHA PEL:300 PPM/400 STEL
ACGIH TLV:300 PPM; 9192
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 15%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VARSOL. PEL AND TLV AS STODDARD SOLVENT.
Fraction by Wt: 5%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:EFTS OF OVEREXP: CHRONIC OVEREXPOS TO PRODUCT CAN PRODUCE
BLOOD DISORDERS AND REVERSIBLE LIVER AND KIDNEY DAMAGE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN:CAN CAUSE
REDNESS/SWELLING/BLISTERS. PRLNGD EXPOS CAN CAUSE DEFATTING,
FOLLICULAR DERMATITIS. EYES:CAN CAUSE IRRIT WITH REDNESS, TEARING &
BLURRED VISION. INHAL: INTOXICATION, BURNING SENSATION I N THE
CHEST, HEADACHE, NAUSEA, VOMITING, WEAKNESS, DROWSINESS, COMA.
INGEST: LOCAL IRRIT, BURNING (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: SENSATION MOUTH, THROAT, STOMACH.
VOMITING, DIARRHEA, DROWINESS, & OTHER INHALATION SYMPTOMS. RAPID
BREATHING, CYANOSIS, TACHYCARDIA INDICATES POSSIBLE ASPIRATION.
THIS IS THEN FOLLOWED BY M ASSIVE PULMONARY EDEMA, HEMORRHAGE.
DEATH FROM ASPHYXIATION POSSIBLE. MAY CAUSE SKIN SENSIT,
PHOTOSENSITIZATION. (ING 4)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/LRG AMTS OF H2O FOR AT LEAST 15 MIN OCCASIONALLY
LIFTING UPPER & LOWER LIDS. SKIN:THORO WASH EXPOS AREA W/SOAP &
H2O. REMOVE CONTAM CLTHG. LAUNDER CONTAM CLTHG BEFORE RE-USE.
INHAL:IF AFF ECTED, REMOVE TO FRESH AIR. IF BRTHG ISDIFFICULT, GIVE
O2. IF BRTHG HAS STOPPED, GIVE ARTF RESP. KEEP PERSON WARM/QUIET &
GET MED ATTN. INGEST: DO NOT INDUCE VOMIT, KEEP PERSON WARM, (SUPP
DATA)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:61.0F,16.1C
Lower Limits:0.9 %
Upper Limits:6 %
Extinguishing Media:DRY CHEMICAL, REGULAR FOAM OR CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT
Unusual Fire/Explosion Hazard:MATL IS HIGHLY VOLATILE & READILY GIVES
OFF VAPS WHICH MAY TRAVEL ALONG THE GROUND/BE MOVED BY VENT & CAUSE
FLASH FIRES/BE IGNITED EXPLO BY PILOT (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID CNTCT W/LIQ/SOLID. AVOID BRTHG VAPORS.
USE PROT MEASURES OUTLINED. SMALL SPILLS: ABSORB LIQ ON ABSORB MATL
& TRANSFER TO HOOD. LRG SPILLS: STOP SPILL AT SOURCE, DIKE AREA OF
SPILL TO PREVENT SPR EADING, PUMP LIQUID TO SALVAGE TANK.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CNTNRS OF THIS MATL MAY BE HAZ WHEN
EMPTIED. SINCE EMPTIED CNTNRS RETAIN PROD RESIDUES (VAP/LIQ & OR
SOLID) OBSERVE ALL HAZ PREC GIVEN IN THE MSDS.
Other Precautions:KEEP CONTAINERS CLOSED TIGHTLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV OF THE PRODUCT OR ANY COMPONENT IS
EXCEEDED, USE NIOSH/MSHA APPROVED SCBA.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL) AND/OR LOCAL
EXHAUST VENTILATION TO MAINAIN EXPOSURE BELOW TLV.
Other Protective Equipment:WEAR IMPERVIOUS CLOTHING AND BOOTS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE & EXPLO HAZ: LIGHTS, OTHER FLAMES, SPARKS, HEATERS, SMOKING,
ELECTRIC MOTORS, OR OTHER SOURCES OF IGNITION AT LOCATIONS DISTANT
FROM MATERIAL HANDLING POINT. FIRST AID PROC: QUIET, AND GET MEDICA
L ATTENTION. ASPIRATION OF MATERIAL INTO THE LUNGS MAY RESULT IN
CHEMICAL PNEUMONITIS WHICH CAN BE FATAL.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:239F,115C
Vapor Pres:15 @ 100 F
Vapor Density:3.8
Spec Gravity:0.893
Evaporation Rate & Reference:9.2 (ETHER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER LIQUID
Percent Volatiles by Volume:55
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAMES.
Hazardous Decomposition Products:BURNING MAY PRODUCE CARBON MONOXIDE
AND/OR CARBON DIOXIDE AND WATER. INCOMPLETE COMBUSTION MAY PRODUCE
TOXIC VAPORS.
==================== Disposal Considerations ====================
Waste Disposal Methods:SMALL SPILL: ALLOW SOLVENT TO EVAP IN HOOD.
DISPOSE OF SOLIDS IN COMPLIANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS. LARGE SPILL: DISPOSE OF IN COMPLIANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:POTASSIUM IODATE
CAGE:HO022
CAGE:HO022
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM IODATE
CAS:7758-05-6
RTECS #:NN1350000
Fraction by Wt: 100%
===================== Hazards Identification =====================
Effects of Overexposure:EYE/SKIN: IRRITATION
======================= First Aid Measures =======================
First Aid:EYE: FLUSH WITH WATER 15 MIN,CONSULT PHYSICIAN. SKIN: WASH
WITH SOAP AND WATER.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Unusual Fire/Explosion Hazard:STRONG OXIDIZER. CONTACT WITH OTHER
MATERIAL MAY CAUSE FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:CAREFULLY SWEEP UP & REMOVE.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE NEAR COMBUSTIBLE
MATERIAL.STORE IN TIGHTLY CLOSED CONTAINER IN A COOL DRY AREA. WASH
THOROUGHTLY AFTER HANDLING.
Other Precautions:KEEP FROM CONTACT WITH CLOTHING AND OTHER COMBUSTIBLE
MATERIAL. AVOID CONTACT WITH EYES,SKIN AND BREATHING DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN.
Ventilation:LOCAL
Other Protective Equipment:APPROVED WORK CLOTHES
Supplemental Safety and Health
MELTING POINT 1040F/560C
================== Physical/Chemical Properties ==================
Spec Gravity:3.89
Solubility in Water:MODERATE
Appearance and Odor:WHITE OR COLORLESS CRYSTALS,ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALUMINUM,ARSENIC,CARBON,METAL SULFIDES,ORGANIC MATTER,SULFUR
==================== Disposal Considerations ====================
Waste Disposal Methods:BY METHODS CONSISTENT WITH LOCAL,STATE AND
FEDERAL REGULATION.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: 950 SUPER RED BARN PAINT
Cage: 4N775
=======================================================
Contractor Summary
=======================================================
Cage: 4N775
=======================================================
Ingredients
=======================================================
Cas: 8052-41-3
RTECS #: WJ8925000
Percent by Wt: 9.44
OSHA PEL: 2900 MG/M3;500 PPM
ACGIH TLV: 525 MG/M3;100 PPM
ACGIH STEL: NOT ESTABLISHED
------------------------------
Cas: 1317-65-3
RTECS #: EV9580000
Percent by Wt: 26.02
OSHA PEL: 15 MG/M3
ACGIH TLV: 10 MG/M3
ACGIH STEL: NOT ESTABLISHED
------------------------------
Cas: 96-29-7
RTECS #: FL9275000
Percent by Wt: .16
ACGIH TLV: 4 MG/KG
------------------------------
Cas: 14807-96-6
RTECS #: WW2710000
Percent by Wt: 14.31
OSHA PEL: SEE TABLE Z-3
ACGIH TLV: 2 MG/M3
ACGIH STEL: NOT ESTABLISHED
------------------------------
Cas: 64741-65-7
Percent by Wt: 6.64
------------------------------
Cas: 1309-37-1
RTECS #: NO7400000
Percent by Wt: 8.67
OSHA PEL: 10 MG/M3
ACGIH TLV: 5 MG/M3;2 PPM
ACGIH STEL: NOT ESTABLISHED
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: YES
Effects of Exposure: ACUTE: INHALATION: IRRITATION OF RESPIRATORY TRACT AND/OR
ACUTE NERVOUS SYSTEM DEPRESSION, CHARACTERIZED BY HEADACHE, DIZZINESS,
STAGGERING GAIT, CONFUSION, UNCONSCIOUSNESS OR COMA. SKIN/EYE: MAY CAUS E
MODERATE SKIN/EYE INJURY WHICH MAY PERSIST FOR SEVERAL DAYS, REDDENING OR
SWELLING. INGESTION OF WET PAINT: IRRITATION OF MUCOUS MEMBRANES AND
GASTROINTESTINAL TRACT.
Signs And Symptions Of Overexposure: CHRONIC: INHALATION: REPORTS HAVE
ASSOCIATED REPEATED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN AND NERVOUS SYSTEM DAMAGE. SOME SOLVENTS MAY CAUSE INJURY TO THE LIVER,
KIDNEY BONE MAR ROW AND BLOOD CELLS AFTER REPEATED EXPOSURE. SKIN/EYE:
REPEATED SKIN CONTACT MAY CAUSE DERMATITIS AND DEFATTING OF SKIN TISSUE.
First Aid: EYE: FLUSH W/WATER FOR 15 MINS, LIFT EYELIDS. SKIN: WASH WITH SOAP
AND WATER. REMOVE CONTAMINATED CLOTHING AND WASH BEFORE REUSE. INHALATION:
REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM AND QUI ET. IF SWALLOWED,
DO NOT INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION (FLAMES, HOT SURFACES,
AND ELECTRICAL, STATIC OR FRICTIONAL SPARKS) AVOID BREATHING VAPORS.
VENTILATE AREA. REMOVE WITH INERT ABSORBENT AND NON-SPARKING TOOLS.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL
REGULATIONS. INCINERATE IN APPROVED FACILITY. DO NOT INCINERATE CLOSED
CONTAINERS.
Handling And Storage Precautions: DO NOT STORE ABOVE 120F. STORE LARGE
QUANTITIES IN BUILDINGS DESIGNED AND PROTECTED FOR STORAGE OF NFPA, CLASS II,
COMBUSTIBLE LIQUIDS. CONTAINERS SHOULD BE GROUNDED WHEN POURING. AVOID FREE
FALL OF L IQUID IN EXCESS OF A FEW INCHES. KEEP OUT OF REACH OF CHILDREN. DO
NOT TAKE INTERNALLY
Other Precautions: DO NOT FLAME CUT, BRAZE OR WELD DRIED FILM W/O NIOSH/MSHA
APPROVED RESPIRATOR OR APPROPRIATE VENTILATION. USE WITH ADEQUATE
VENTILATION. DO NOT BREATHE VAPOR/SPRAY MIST. NEVER FLAME CUT, BRAZE OR WEL D
EMPTY PAINT CONTAINERS OR PAINTED SURFACES BEFORE THOROUGHLY DRY.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: 100-104F
Lower Limits: 0.9
Extinguishing Media: USE NFPA CLASS B EXTINGUISHERS (DRY CHEMICAL, FOAM, CARBON
DIOXIDE) DESIGNED TO EXTINGUISH NFPA CLASS II LIQUID FIRES.
Fire Fighting Procedures: KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE FROM HEAT,
NON-EXPLOSION PROOF ELECTRICAL EQUIPMENT, SPARKS AND OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT. DO NOT APPLY TO VERY HOT
SURFACES.
Unusual Fire/Explosion Hazard: DO NOT USE WATER EXCEPT FOR COOLING CLOSED
CONTAINERS TO PREVENT PRESSURE BUILD UP AND EXPLOSION WHEN EXPSOED TO EXTREME
HEAT. USE FOG NOZZLES IF WATER IS USED. FIREFIGHTERS SHOULD BE EQUIPPED WITH
MA SKS AND SELF CONTAINED RESPIRATORS.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IN OUTDOOR/OPEN AREAS , USE NIOSH/MSHA APPROVED
MECHANICAL FILTER RESPIRATOR TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY.
IN RESTRICTED VENTILATION AREAS, USE NIOSH/MSHA APPROVED CHEMICAL-MECHANI
CAL FILTERS, DESIGNED TO REMOVE A COMBINATION OF PARTICULATE GAS/VAPOR. IN
CONFINED AREAS, USE NIOSH/ APPROVED AIRLINE TYPE RESPIRATOR/HOODS
Ventilation: GENERAL DILUTION/LOCAL EXHAUST TO KEEP TLV BELOW LIMIT & TO
REMOVE DECOMPOSITION PRODUCTS DURING WELDING/FLAME CUTTING ON SURFACE COATED
W/PRODUCT
Other Protective Equipment: PREVENT PROLONGED SKIN CONTACT TO CONTAMINATED
CLOTHING. WEAR APPROPRIATE, PROPERLY FITTED RESPIRATOR DURING/AFTER
APPLICATION UNLESS AIR MONITORING INDICATES VAPOR/MIST LEVELS BELOW LIMITS.
Work Hygienic Practices: INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND
INHALING THE CONTENTS MAY BE HARMFUL OR FATAL. AVOID CONTACT WITH EYES, SKIN
AND CLOTHING. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health: WEIGHT PER GALLON 11.3-11.9 FOR PAINT
CONTAINING LEAD:DO NOT USE ON TOYS/FURNITURE/SURFACES OF OTHER ARTICLES
CHEWED BY CHILDREN. FLAME CUTTING/BRAZING &WELDING OF DRY FILMS WILL
RESULT IN LEAD OXIDES FUMES WHICH WILL CONTRIBUTE TO LEAD EXPOSURE. AVOID
CONTAMINATION BY TOUCHING CONTAMINATED CLOTHING THEN HANDLING FOOD
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 125-406 F
Vapor Density: >AIR
Evaporation Rate & Reference: SLOWER THAN ETHER
Percent Volatiles by Volume: 16.25
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: AVOID EXTREME HEAT
Materials To Avoid: ISOLATE FROM STRONG OXIDIZERS SUCH AS PERMANGANATE
Hazardous Decomposition Products: NONE
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NONE
=======================================================
Toxicological Information
=======================================================
=======================================================
=======================================================
Transport Information: COMBUSTIBLE LIQUID CLASS II
=======================================================
Regulatory Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: 950 SUPER RED BARN PAINT
Cage: 4N775
Company Name: IOWA PAINT MFG CO INC
Street: 17TH & GRAND
Zipcode: 50305-5000
Label Required IND: Y
Date Of Label Review: 01/04/2001
Status Code: A
Origination Code: G
Hazard And Precautions: ACUTE: INHALATION: IRRITATION OF RESPIRATORY TRACT
AND/OR ACUTE NERVOUS SYSTEM DEPRESSION, CHARACTERIZED BY HEADACHE, DIZZINESS,
STAGGERING GAIT, CONFUSION, UNCONSCIOUSNESS OR COMA. SKIN/EYE: MAY CAUS E
MODERATE SKIN/EYE INJURY WHICH MAY PERSIST FOR SEVERAL DAYS, REDDENING OR
SWELLING. INGESTION OF WET PAINT: IRRITATION OF MUCOUS MEMBRANES AND
GASTROINTESTINAL TRACT.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ECCOBOND 24,PART B
Kit Part:Y
CAGE:04552
CAGE:04552
CAGE:60047
============= Composition/Information on Ingredients =============
Ingred Name:DIETHYLENE GLYCOL DI(3-AMONOPROPYL) ETHER
Fraction by Wt: >95%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CORROSIVE. MAY CAUSE SKIN AND
EYE BURNS. INHALATION MAY CAUSE RESPIRATORY TRACT IRRITATION.
HARMFUL IF INGESTED. CHRONIC: NOT KNOWN.
Explanation of Carcinogenicity:NONE OF THE INGREDIENTS IN THIS PRODUCT
IS LISTED BY NTP, IARC OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYES: VERY SEVERE IRRITATION. CAN CAUSE
PERMANENT DAMAGE OR BLINDNESS. SKIN: VERY SEVERE IRRITATION. MAY
CAUSE BURNS AND BLISTERING. INHALATION: RESPIRATORY TRACT
IRRITATION. INGESTION: HARMFUL IF SWA LLOWED.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH A HISTORY OF SKIN
AND RESPIRATORY DISORDERS MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH PLENTY OF WATER UNTIL MEDICAL ATTENTION CAN
BE OBTAINED. SEE DOCTOR. SKIN: REMOVE CONTAMINATED CLOTHING. WASH
WITH SOAP AND WATER. IF BURNS RESULT, SEE DOCTOR. INHALATION:
REMOVE VICT IM TO FRESH AIR. GIVE OXYGEN/CPR IF NEEDED. SEE DOCTOR.
INGESTION: DRINK LARGE AMOUNTS OF WATER. DO NOT INDUCE VOMITING.
SEE DOCTOR IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:260F,127C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE PERSONNEL. ELIMINATE IGNITION SOURCES.
VENTILATE AREA. WEAR PROTECTIVE CLOTHING AND EQUIPMENT. ABSORB IN
INERT MATERIAL AND PLACE IN APPROPIATE DISPOSAL CONTAINER AND
COVER. SCRUB AREA WITH SOA P AND WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE, HEAT, IGNITION SOURCES AND
INCOMPATIBLE MATERIALS. KEEP CONTAINERS CLOSED.
Other Precautions:AVOID EYE AND SKIN CONTACT. DO NOT BREATHE VAPORS.
EMPTY CONTAINERS RETAIN HAZARDOUS RESIDUE. TREAT THEM AS IF THEY
WERE FULL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WITH ADEQUATE VENTILATION.
NIOSH/MSHA-APPROVED RESPIRATOR OR SCBA AS APPROPIATE FOR EXPOSURE
OF CONCERN.
Ventilation:MECHANICAL (GENERAL) VENTILATION OR LOCAL EXHAUST
VENTILATION TO KEEP EXPOSURE LEVELS BELOW PEL.
Other Protective Equipment:PROTECTIVE CLOTHING AS REQUIRED TO MINIMIZE
EXPOSURE FROM PROLONGED OR REPEATED CONTACT. EYE BATH AND SAFETY
SHOWER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
KEY1:C2.
================== Physical/Chemical Properties ==================
HCC:B2
Boiling Pt:B.P. Text:>480F,>249C
Vapor Pres:<1
Spec Gravity:1.00
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS TO SLIGHTLY YELLOW LIQUID.
Percent Volatiles by Volume:NEGL.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDERS, PEROXIDES, EPOXIDES.
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES, UNCONTROLLED
MIXING.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
NITROGEN OXIDES. REACTION WITH RESIN IS EXOTHERMIC, SMOKE OR TOXIC
FUMES EVOLVED
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:889 3448 SILVER RECOVERY SOLUTION, PART A
Kit Part:Y
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM CARBONATE
CAS:584-08-7
RTECS #:TS7750000
Fraction by Wt: 10-15%
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 75-80%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TRIMERCAPTO-S-TRIAZINE,TRISODIUM SALT
CAS:17766-26-6
Fraction by Wt: 10-15%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RATS): 7878 MG/KG
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTAINS:TRIMERCAPTO-S-TRIAZINE,
TRISODIUM SALT.MAY CAUSE KIDNEY DAMAGE BASED ON ANIMAL DATA.
EXPECTED TO BE A LOW INHALATION HAZARD FOR RECOMMENDED HANDLING.
EYE CONTACT CAUSES BURNS.EXPECTED TO BE A LOW SKIN CONTACT HAZARD
FOR RECOMMENDED HANDLING. HARMFUL IF SWALLOWED. MAY CAUSE
IRRITATION OF GASTROINTESTINAL TRACT.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:KIDNEY DAMAGE, EYE BURNS, GI TRACT IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH WATER FOR 15 MINUTES. GET
MEDICAL ATTENTION ASAP. INHALATION: MOVE TO FRESH AIR. TREAT
SYMPTOMATICALLY. GET MEDICAL ATTENTION. SKIN: IMMEDIATELY REMOVE
CONTAMINATED CLOTHI NG AND WASH WITH SOAP AND WATER. GET MEDICAL
ATTENTION. INGESTION: ONLY INDUCE VOMITING AT THE INSTRUCTION OF
MEDICAL PERSONNEL. NEVER GIVE ANYTHING BY MOUTH IF UNCONSCIOUS.
CALL PHYSICIAN ASAP.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE (CO2), DRY CHEMICAL,
ALCOHOL FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER W/LG AMTS OF WATER.OTHERWISE
ABSORB W/VERMICULITE OR OTHER INERT MATERIAL, THEN PLACE IN
CONTAINER FOR CHEMICAL WASTE. CLEAN SURFACE THOROUGHLY TO REMOVE
RESIDUAL CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT GET IN EYES. AVOID CONTACT WITH
SKIN & CLOTHING. KEEP AWAY FROM INCOMPATIBLE SUBSTANCES. KEEP FROM
CONTACT WITH OXIDIZING MATERIALS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES/HR)
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:EYEBATH, WASHING FACILITIES, SAFETY SHOWER.
PROTECTIVE CLOTH APPROPRIATE FOR RISK OF EXPOSURE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
KEY1:B2.
================== Physical/Chemical Properties ==================
HCC:B2
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Decomp Temp:Decomp Text:NOT GIVEN
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.23
pH:12.5
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE.
Appearance and Odor:LIQUID, LIGHT YELLOW COLOR, ODORLESS.
Percent Volatiles by Volume:75-80
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
OXIDES OF NITROGEN, OXIDES OF SULFUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:MCR HIGH BUILD SEMI-GLOSS EPOXY CONVERTER (SUPDAT)
Kit Part:Y
CAGE:50411
CAGE:50411
============= Composition/Information on Ingredients =============
RTECS #:9999999ZZ
Ingred Name:XYLENE (SARA III). VP:5 @ 20C.
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 25%
OSHA PEL:100 PPM;150 PPM STEL
ACGIH TLV:100 PPM;150 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYLBENZENE (SARA III). VP:7.1 @ 20C.
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 7%
OSHA PEL:100 PPM;125 PPM STEL
ACGIH TLV:100 PPM;125 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC: (SOLVENT
NAPHTHA (PETROLEUM LIGHT AROMATIC)). VP:3 @ 20C.
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 6%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:PROPYLENE GLYCOL MONOMETHYL ETHER. VP:8 @ 20C.
CAS:107-98-2
RTECS #:UB7700000
Fraction by Wt: 6%
OSHA PEL:100 PPM;150 PPM STEL
ACGIH TLV:100 PPM;150 PPM STEL
Ingred Name:BARIUM SULFATE
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: 15%
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:SUPDAT:WORKMEN ARE EXPOSED TO SPRAY APPLICATION/ABRASIVE
BLAST CLEANING, ENGINEERING & ADMIN CONTROLS MUST BE (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:USED TO MAINTAIN EXPOS LEVEL BELOW OSHA REQD LEVEL,
OR USE NIOSH/MSHA APPRVD MECH FILTER RESP FOR PROT.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:TO REMOVE PARTICULATES, GAS & VAPOR. IN CONFINED
AREAS, USE NIOSH/MSHA APPRVD AIR-LINE RESPIRATORS & HOOD.
RTECS #:9999999ZZ
Ingred Name:VENT:TO REMOVE DECOMPOSITION PRODUCTS DURING WELDING &
FLAME CUTTING OF SURFACES COATED W/THIS PRODUCT.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:IRRIT OF RESP TRACT/ACUTE
NERV SYS CAUSING HDCH, DIZZ, NAUS. EYE & SKIN:PRIMARY IRRIT.
CHRONIC:DIRECT EYE CONT MAY CAUSE BURNS, PERM EYE DMG & POSS
BLINDNESS. INHAL OF SOLV VAP MAY CAUSE N OSE & THROAT IRRIT & DIZZ,
NAUS, HDCH &SLEEPINESS. OVEREXP/INTENT INHAL OF VAP MAY CAUSE ACUTE
HEART (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:ABNORMS. DIRECT SKIN CONT MAY CAUSE
BURNS, IRRIT, ALLERGY & PHOTOSENSIT. SOLV CAN BE ABSORBED INTO BODY
THRU SKIN. PRLNG/RPTD OVEREXP MAY CAUSE ANEMIA, NERV SYS, LIVER,
KIDNEY, SPLEEN, HEART & EYE DMG.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE FROM EXPOSURE. KEEP
WARM & QUIET. NOTIFY MD. EYES:FLUSH IMMEDIATELY W/LARGE AMOUNTS OF
WATER FOR AT LEAST 15 MINUTES. TAKE TO MD FOR MEDICAL TREATMENT.
SKIN:WASH AFFECTED AREAS W/LARGE AMOUNTS OF WATER. REMOVE
CONTAMINATED CLOTHING.
===================== Fire Fighting Measures =====================
Flash Point:74.0F,23.3C
Lower Limits:0.7-1%
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. IN ABSENCE OF ELEC, WATER SPRAY (FOG NOZZ IS PREF) MAY BE USED TO
COOL CNTNRS. AVOID EXPOS TO DECOMP.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, SPARKS, ELECTRICAL EQUIPMENT & OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT (FLAMES, HOT
SURFACES & ELECTRICAL, STATIC OR FRICTION SPARKS). AVOID BREATHING
VAPORS, WEAR NIOSH/MSHA APPROVED RESPIRATOR & VENT AREA. REMOVE
W/INERT ABSORBANT SUCH AS SA ND, KITTY LITTER, ETC & USE
NON-SPARKING TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:SECURE CLOSURES & KEEP CNTNRS UPRIGHT
TO PVNT LEAKAGE. STORE LG QTYS ONLY IN BLDGS DESIGNED TO COMPLY
W/OSHA 1910.106. DO NOT STORE >120F.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT GET IN EYES/ON SKIN.
AVOID BRTHG VAPS/SPRAY MIST. DO NOT STORE/USE NEAR HEAT, SPKS/OPEN
FLAME. CNTNRS SHLD BE GROUNDED WHEN POURING. AVOID FREE FALL OF LIQ
IN EXCESS OF A FEW INCHES. DO NOT FLAME CUT, (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN OUTDOOR/OPEN AREAS W/UNRESTRICTED VENT, USE
NIOSH/MSHA APPRVD MECH FILTER RESP TO REMOVE SOLID AIRBORNE
PARTICLES OF OVERSPRAY DURING SPRAY APPLICATIONS. IN RESTRICTED
VENT AREAS, USE NIOSH/MSHA AP PRVD MECH FILTER RESPS DESIGNED (ING
8)
Ventilation:PROVIDE GEN DILUTION/LOC EXHST VENT IN VOL & PATTERN TO
KEEP TLV BELOW STATED OSHA LIMS & LEL BELOW STATED LIM & (ING 9)
Other Protective Equipment:AS NEEDED - USE BODY PROTECTION, SUCH AS
RUBBER APRON, ETC.
Work Hygienic Practices:BEFORE SMOKING OR EATING, WASH HANDS
THOROUGHLY.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:PART B, 4356B. OTHER PREC:BRAZE/WELD W/OUT
NIOSH/MSHA APPRVD MECH FILTER RESP/APPROP & ADEQ VENT. ALL ELEC
EQUIP & INSTALLATIONS SHLD BE MADE & GROUNDED I/A/W NATIONAL ELEC
CO DE. WORKMEN ARE REQD TO USE ONLY NON-FERROUS TOOLS & WEAR
NON-SPARKING SHOES IN AREAS WHERE EXPLO HAZS EXIST. IF (ING 6)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>276F,>136C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.31
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:54
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE KNOWN
Hazardous Decomposition Products:MAY PRODUCE HAZ FUMES WHEN HEATED TO
DECOMPOSITION AS IN WELDING. FUMES MAY PRODUCE CARBON DIOXIDE &
CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A SAFE MANNER I/A/W LOCAL, STATE &
FEDERAL REGULATIONS THAT APPLY TO INCINERATION OR SECURE LANDFILL.
| 1 |
gloves_mandatory
|
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.