text
stringlengths 542
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:MAC'S BLACK TIRE PAINT CONCENTRATE
CAGE:72527
CAGE:72527
============= Composition/Information on Ingredients =============
Ingred Name:FUEL OIL, NO. 2
CAS:68476-30-2
RTECS #:LS8930000
Fraction by Wt: 1-5%
Ingred Name:STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 35-40%
Other REC Limits:525 MG/CUM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:ASPHALT OXIDE *93-1*
CAS:64742-93-4
Fraction by Wt: 55-60%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION. SKIN:
MODERATE IRRITATION/DERMATITIS. INHALATION: MAY CAUSE NASAL &
RESPIRATORY IRRITATION EFFECTS, DEATH. INGESTION: GI IRRITATION.
ASPIRATION INTO THE LUNGS CAN CAUSE CHEMIC AL PNEUMONITIS WHICH CAN
BE FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION/REDNESS/TEARING/BLURRED
VISION/DEFATTING/DIZZINESS/WEAKNESS/FATIGUE/NAUSEA/HEADACHE/VOMITIN
G/DIARRHEA
======================= First Aid Measures =======================
First Aid:SKIN: WASH AREA W/SOAP & WATER. EYES: FLUSH W/PLENTY OF
WATER. INGESTION: DON'T INDUCE VOMITING. KEEP PERSON WARM & QUIET.
ASPIRATION HAZARD. INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN/CPR
IF NECESS ARY. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:120F-140F
Lower Limits:1.0
Extinguishing Media:REGULAR FOAM/CO2/DRY CHEMICAL
Fire Fighting Procedures:WEAR SCBA W/FULL FACEPIECE OPERATED IN
POSITIVE PRESSURE DEMAND MODE. WATER & FOAM MAY CAUSE FROTHING
BECOME VIOLENT & ENDANGER THE FIREFIGHTER.
Unusual Fire/Explosion Hazard:NEVER USE WELDING/CUTTING TORCH ON/NEAR
DRUM, EVEN EMPTY, PRODUCT CAN IGNITE EXPLOSIVELY. VAPORS ARE >AIR &
MAY TRAVEL ALONG THE GROUND/MOVED BYSEE SUPP
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: ABSORB ON PAPER/VERMICULITE/FLOOR
ABSORBENT/OTHER MATERIAL. LARGE: ELIMINATE IGNITION SOURCES.
EVACUATE AREA. STOP AT SOURCE & DIKE/PUMP INTO SALVAGE TANK.
REMAINING LIQUID MAY BE TAKEN UP W AB SORBENT MATERIAL & SHOVELED
INTO CONTAINERS. SUPP
======================Handling and Storage ======================
Handling and Storage Precautions:CONTAINERS OF THIS MATERIAL MAY BE
HAZARDOUS WHEN EMPTIED. EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES,
OBSERVE ALL HAZARD PRECAUTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR
WHERE EXPOSURE LIMITS HAVE EXCEEDED.
Ventilation:MECHANICAL (GENERAL) LOCAL EXHAUST
Other Protective Equipment:IMPERVIOUS CLOTHING & BOOTS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
UNUSUAL FIRE HAZARD CON'D: VENTILATION & IGNITE BY AN IGNITION SOURCE
DISTANT FROM HANDLING POINT. SPILL PROCEDURE CON'T: PREVENT RUN-OFF
TO SEWERS & OTHER BODIES OF WATER. NOTIFY AUTHORITIES.
================== Physical/Chemical Properties ==================
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:BLACK LIQUID SLURRY
Percent Volatiles by Volume:35-40
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT/FLAME/IGNITION SOURCES
Hazardous Decomposition Products:CO2, CO, VARIOUS HYDROCARBONS
==================== Disposal Considerations ====================
Waste Disposal Methods:SMALL: DEPOSIT IN A LANDFILL IN ACCORDANCE
W/LOCAL/STATE & FEDERAL REGULATIONS. LARGE: DESTROY BY LIQUID
INCINERATION IN ACCORDANCE W/LOCAL/STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DIETHYLENETRIAMINE, 99%, D9385-6
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:DIETHYLENE TRIAMINE
CAS:111-40-0
RTECS #:IE1225000
Fraction by Wt: 99%
OSHA PEL:1 PPM
ACGIH TLV:S, 1 PPM; 9192
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE SUPP DATA
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: HARMFUL IF
SWALLOWED/INHALED/ABSORBED THRU SKIN. MATL IS EXTREMELY DEST TO
TISS OF MUC MEMB & UPPER RESP TRACT/EYES/SKIN. INHAL MAY BE FATAL
AS RESULT OF SPASM, INFLAM & EDEMA OF LARYNX & BRONC HI, CHEM PNEUM
& PULM EDEMA. MAY CAUSE ALLERGIC RESP & SKIN RXN. CHRONIC: DMG TO
LIVER & KIDNEYS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:BURNING SENSATION, COUGHING, WHEEZING,
LARYNGITIS, SHORTNESS OF BREATH, HEADACHE, NAUSEA AND VOMITING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES & SKIN: IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF WATER
FOR AT LEAST 15 MINUTES WHILE REMOVING CONTAMINATED CLOTHING AND
SHOES. WASH BEFORE REUSE. DISCARD CONTAMINATED SHOES. ASSURE ADEQ
FLUSHING OF EYES BY SEPARATING LIDS WITH FINGERS. INHAL: REMOVE TO
FRESH AIR. IF NOT BREATHING GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. CALL MD. INGEST: CALL MD
IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:202F,94C
Extinguishing Media:CO*2, DRY CHEMICAL POWDER, ALCOHOL OR POLYMER FOAM.
WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND PROTECTIVE
CLOTHING TO PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:EVAC AREA. WEAR NIOSH/MSHA APPRVD SCBA, RUBBER
PLACE IN CLOSED CONTAINERS FOR DISPOSAL. VENTILATE AREA AND WASH
SPILL SITE AFTER MATERI AL PICKUP IS COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT BREATHE VAPOR. KEEP TIGHTLY
CLOSED. STORE IN A COOL DRY PLACE.
Other Precautions:DO NOT GET IN EYES, ON SKIN OR CLTHG. AVOID
PRLNGD/RPTD EXPOS. READILY ABSORBED THRU SKIN. CORR. SENSIT.
DIETHYLENETRIAMINE (DETA) HAS BEEN RPTD TO FORM COMPLEXES W/SILVER,
COBALT OR CHROMIUM WHICH CA N BE EXPLO. IT HAS BEEN (SEE SUPP DATA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:PROTECTIVE CLOTHING, SAFETY SHOWER AND EYE
BATH.
Work Hygienic Practices:WASH THOROUGHLY AFTER USE AND BEFORE EATING,
DRINKING, SMOKING OR USING SANITARY FACILITIES .
Supplemental Safety and Health
LD50-LC50 MIX: LD50:(ORL,RAT) 1080 MG/KG, (IPR,RAT) 74 MG/KG, (IPR,MUS)
71 MG/KG, (SKN,RBT) 1090 MG/KG, (SKN,GPG) 162 MG/KG. OTHER PREC:
REPORTED TO CAUSE SPONTANEOUS IGNITION OF CELLULOSE NITRATE.
================== Physical/Chemical Properties ==================
HCC:C2
Boiling Pt:B.P. Text:390F,199C
Melt/Freeze Pt:M.P/F.P Text:-31F,-35C
Vapor Pres:0.37 @ 20C
Vapor Density:3.56
Spec Gravity:0.955
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS TO YELLOW LIQUID W/A PUNGENT,
AMMONIA-LIKE ODOR .
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS, COPPER & COPPER ALLOYS.
Stability Condition to Avoid:ABSORBS CO*2 FROM AIR.
Hazardous Decomposition Products:TOXIC FUMES OF: CO, CO*2 & NO*X.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE OR MIX THE MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. DISPOSE OF IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL LAWS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ELVAX, 3182
Preparer's Name:T E SCHROER
CAGE:18873
CAGE:18873
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE-VINYL ACETATE COPOLYMER
> Wt:99.7
Ingred Name:VINYL ACETATE AEL DUPONT: 10 PPM - 8 & 12 HR TWA. WHERE
GOVERNMENTALLY IMPOSED OCCUP EXPOS LIMITS WHICH ARE LOWER THAN AEL
ARE IN EFT, SUCH LIMITS SHALL TAKE PRECEDENCE.
CAS:108-05-4
RTECS #:AK0875000
< Wt:.3
ACGIH TLV:35 MG/M3;10 PPM
ACGIH STEL:53 MG/M3;15 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL,RAT) 2920 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:BEFORE USING "ELVAX" RESINS, READ
BROCHURES ON SAFE HNDLG PROCEDURES. ACUTE: INGEST: THE ORAL LD-50
IN RATS USING 1 TYPE OF "ELVAX" IS IN EXCESS OF 1000 MILLIGRAMS PER
KILOGRAM OF BODY WT. 2 WEEK META BOLIC TESTS WITH DOGS & RATS
SHOWED THAT NO SIGNIFICANT AMOUNT OF POLYMER WAS RETAINED BY
ANIMALS. 90-DAY FEEDING STUDIES IN RATS SHOWED THAT "ELVAX" RESINS
HAVE LOW TOX. SLIGHT LIVER EFTS WERE SEEN I N ANIMALS FED DIETS
CNTNG 10% "ELVAX"; NO EFTS WERE SEEN W/DIETS CNTNG 5% "ELVAX".
OVERALL, NO IMPORTANT BODY SYSTEMS OR ORGAN DYSFUNCTION OCCURRED AT
EITHER DOSE LEVEL. SKIN: NO DATA AVAILABLE. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:VINYL ACETATE. IARC MONOGRAPHS; VOL 63,
PG 443, 1995: GROUP 2B.
Effects of Overexposure:HLTH HAZS: HOWEVER, BASED ON EXPERIENCE W/HNDLG
THESE POLYMERS, NO UNUSUAL DERM HAZ IS EXPECTED FROM ROUTINE HNDLG.
MOLTEN POLYMER CONTACTING SKIN WILL CAUSE THERMAL BURNS. EYE:
MECHANICAL IRRITATION. INHAL: POLYMER IS NOT RESPIRABLE AS
MARKETED. AT PROCESSING TEMPS ABOVE 204 DEGREES C, FUMES IRRITATING
TO EYES, NOSE, AND THROAT MAY BE PRODUCED. EXPOSURE MAY RESULT IN
REDNESS, TEARING, AND ITCHING IN THE EYES TOGETHER WITH SORENESS
IN THE NOSE AND THROAT WITH COUGHING.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTF RESP. IF
BRTHG IS DFCLT, GIVE OXYG. CALL PHYS. SKIN CONT: CMPD IS NOT LIKELY
TO BE HAZ BY SKIN CONT BUT CLEANSING SKIN AFTER USE IS ADVISABLE.
IF MO LTEN MATL GET ON SKIN, COOL RAPIDLY W/COLD WATER. DO NOT
ATTEMPT TO REMOVE MATL FROM SKIN. OBTAIN MEDICAL TREATMENT FOR
THERMAL BURN. EYE CONT: IMMEDIATELY FLUSH W/PLENTY OF WATER FOR AT
LST 15 MINUTE S. CALL PHYSICIAN. INGEST: NO SPECIFIC INTERVENTION
IS INDICATED AS CMPD IS NOT LIKELY TO BE HAZ BY INGEST. CONSULT
PHYSICIAN IF NECESSARY.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:=260.C, 500.F
Extinguishing Media:WATER, FOAM, DRY CHEMICAL, CO*2.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:SOLID POLYMER CAN BE COMBUSTED ONLY
W/DFCLTY. ELECTROSTATIC CHARGE CAN POTNTLY BUILD UP WHEN POURING
PELLETS. GROUNDING OF EQUIP IS REC. HAZ COMBUST PRODS: COMPLETE
COMBUST GIVE CO*2 & WATER. INCOMPLE TE COMBUST GIVES, IN ADDN, CO &
HYDROCARBON OXIDATION PRODS INCL ORGANIC ACIDS, ALDEHYDES, AND
ALCOHOLS.
================== Accidental Release Measures ==================
Spill Release Procedures:SAFEGUARDS (PERSONNEL). NOTE: REVIEW FIRE
FIGHTING MEASURES & HANDLING (PERSONNEL) SECTION BEFORE PROCEEDING
WITH CLEAN-UP. USE APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT DURING
CLEAN-UP. SPILL CLEAN U P: SHOVEL OR SWEEP UP.
======================Handling and Storage ======================
Handling and Storage Precautions:SEE FIRST AID AND PERSONAL PROTECTIVE
EQUIPMENT SECTIONS.
Other Precautions:STORE IN A COOL, DRY PLACE. KEEP CONTAINER CLOSED TO
PREVENT CONTAMINATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH APPRVD AIR PURIFYING RESP W/ORG VAP
CARTRIDGE WITH DUST/MIST FILTER MAY BE PERMISSIBLE UNDER CERTAIN
CIRCUMSTANCES WHERE AIRBORNE CONCS ARE EXPECTED TO EXCEED EXPOS
LIMITS. USE NIOSH APPRVD PO SITIVE PRESS AIR SUPPLIED RESP IF THERE
IS ANY POTNTL FOR UNCONTROLLED RELEASE, EXPOS LEVELS ARE NOT
KNOWN/ANY OTHER CIRCUMSTANCES WHERE NIOSH APPRVD (SUPDAT)
Ventilation:LOC VENT MUST BE USED OVER PROCESSING EQUIP TO MAINTAIN
VINYL ACETATE CONCS IN AIR BELOW PEL. USE STATIC CTLS. STATIC
CHARGES CAN BUILD UP (SUPDAT)
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER . IF
THERE IS POTNTL CONT WITH HOT/MOLTEN MATERIAL, WEAR HEAT RESISTANT
CLOTHING AND FOOTWEAR.
Supplemental Safety and Health
RESP PROT: NIOSH APPRVD AIR PURIFYING RESPS MAY NOT PROVIDE ADEQ PROT.
VENT: AND IGNITE DUST/SOLV LADEN ATM. TOX INFO: RATS BUT NOT IN
MICE. RESEARCH ON MECHANISM OF NASAL TUMOR INDUCTION IN RATS SUGG
ESTS THAT LEVELS @ WHICH HUMANS ARE LIKELY TO BE EXPOS ARE BELOW
THRESHOLD FOR EFTS THAT CONTRIBUTE TO (OTHER INFO)
================== Physical/Chemical Properties ==================
Spec Gravity:0.93-0.97
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TRANSLUCENT TO WHITE PELLETS. MILD ESTER-LIKE ODOR.
Percent Volatiles by Volume:NEGLIGIBLE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE OR CAN REACT WITH STRONG ACIDS, OXIDIZING AGENTS.
Stability Condition to Avoid:TEMPERATURES ABOVE 230 DEGREES C FOR SHORT
RESIDENCE TIMES. TEMPERATURES ABOVE 204 DEGREES C FOR LONG
RESIDENCE TIMES.
Hazardous Decomposition Products:VINYL ACETATE, ACETIC ACID, CARBON
MONOXIDE AND HYDROCARBON OXIDATION PRODUCTS INCLUDING ORGANIC
ACIDS, ALDEHYDES AND ALCOHOLS.
=================== Toxicological Information===================
Toxicological Information:ANIMAL DATA: VINYL ACETATE. INHAL 4 HR LC50:
4000 PPM IN RATS. SKIN ABSORP LD50: 2335 MG/KG IN RABBITS. ORAL
LD50: 2920 MG/KG IN RATS. VINYL ACETATE IS SLIGHT SKIN & SEV EYE
IRRITANT, & WEAK SKIN SENS ITIZER IN ANIMALS. NO EFTS FROM RPTD
EXPOS TO VINYL ACETATE BY INHAL WERE OBSERVED @ 100 PPM IN RATS.
EXPOS TO HIGHER CONCS OF VINYL ACETATE BY INHAL CAUSED EYE IRRIT &
LACRIMATION, REDUCED WT GAIN, & IRRIT OF RESP TRACT W/BRTHG
DFCLTY. EFTS OBSERVED IN RATS & MICE EXPO BY INHAL TO 200 & 600 PPM
FOR 2 YRS INCL REDUCED BODY WT, & PATHOLOGICAL CHANGES IN NOSE &
RESP TRACT. NASAL CAVITY TUMORS WERE O BSERVED IN (SUPDAT)
===================== Ecological Information =====================
Ecological:AQUATIC TOXICITY: NO INFORMATION IS AVAILABLE. TOXICITY IS
EXPECTED TO BE LOW BASED ON INSOLUBILITY IN WATER.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREFERRED OPTIONS FOR DISP ARE (1) RECYCLING,
(2) INCINERATION W/ENERGY RECOVERY, AND (3) LANDFILL. HIGH FUEL
VALUE OF PROD MAKES OPTION 2 VERY DESIRABLE FOR MATL THAT CANNOT BE
RECYCLED. TREATMENT, S TORAGE, TRANSPORTATION, & DISP MUST BE I/A/W
APPLIC FEDERAL, STATE/PROVINCIAL, & LOCAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:SHIPPING INFORMATION. DOT HAZARD CLASS: NOT
REGULATED.
===================== Regulatory Information =====================
SARA Title III Information:VINYL ACETATE: DISCLOSURE AS A TOXIC
CHEMICAL IS REQUIRED UNDER SECTION 313 OF TITLE III OF THE
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 AND 40 CFR
PART 372.
Federal Regulatory Information:U.S. FEDERAL REGULATIONS. TSCA INVENTORY
STATUS: IN COMPLIANCE WITH TSCA INVENTORY REQUIREMENTS FOR
COMMERCIAL PURPOSES.
State Regulatory Information:STATE RIGHT-TO-KNOW. NO SUBSTANCES ON
STATE HAZ SUBSTANCES LIST, FOR STATES INDICATED BELOW, ARE USED IN
MFR OF PRODS ON THIS MSDS, W/EXCEPTIONS INDICATED. SUBSTANCED ON
PENNSYLVANIA HAZ SUBSTANCES LI ST PRESENT @ CONC OF 1%/MORE (0.01%
FOR SPEC HAZ SUBSTANCE) - NONE KNOWN. WARNING - SUBSTANCES KNOWN TO
STATE OF CALIFORNIA TO CAUSE CANCER, BIRTH DEFECTS/OTHER REPRO HARM
- NONE KNOWN. SUBSTANCES ON NEW JERSEY WORKPLACE HAZ SUBSTANCE
LIST PRESENT @ CONC OF 1%/MORE (0.1% FOR SUBSTANCES IDENTIFIED AS
CARCINS, MUTAGENS/TERATOGENS) - NONE KNOWN.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NON-FLAMMABLE FOAM INSULATION ADHESIVE, 238
CAGE:EO927
CAGE:11761
CAGE:EO927
============= Composition/Information on Ingredients =============
Ingred Name:VM&P NAPHTHA; (PETROLEUM DISTILLATE) VP: 10 @ 60F
CAS:64742-89-8
Fraction by Wt: 3-6%
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:MINERAL OIL; (PETROLEUM OIL) VP: NIL
CAS:8012-95-1
RTECS #:PY8030000
Fraction by Wt: 5-8%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3 (MIST)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NO LONG TERM LABORATORY TESTS TO
DETERMINE CHRONIC EFFECTS. CONTAINS AN INGREDIENT SIMILAR TO
MINERAL OILS REPORTED TO INDUCE CANCER IN LABORATORY ANIMALS. THERE
IS NO EVIDENCE OF ANY ADVERSE EFFECTS ON HUMANS IF SIMPLE
PRECAUTIONS ARE TAKEN USING PROTECTIVE EQUIPMENT AND GOOD PERSONAL
HYGIENE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:UNKNOWN.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMEDIATELY . INHAL: REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE OXYGEN/ARTIFICIAL RESPIRATION) . EYES:
IMMEDIATELY FLUSH W/POTABLE WATER FOR A MINIMUM OF 15 MINUTES, SEEK
ASSISTANCE FROM MD . SKIN: FLUSHW/COPIOUS AMOUNTS OF WATER. CALL
MD .
===================== Fire Fighting Measures =====================
Flash Point:>200F,>93C
Lower Limits:NONE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP INTO CONTAINER AND ALLOW TO DRY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NORMAL STORAGE AND HANDLING.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NORMAL VENTILATION.
Other Protective Equipment:NONE.
Work Hygienic Practices:WASH SKIN WITH SOAP AND WATER OR WATERLESS
CLEANER. FLUSH EYES WITH WATER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.282
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:40-55
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
UNKNOWN.
Stability Condition to Avoid:UNKNOWN.
Hazardous Decomposition Products:UNKNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS . NORMAL SOLID WASTE DISPOSAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DPE000093, CARTRIDGE FOR POWER DEVICE, (SUPP DATA)
CAGE:8X135
CAGE:8X135
CAGE:53084
============= Composition/Information on Ingredients =============
Ingred Name:CASE MATERIAL; (SHELLCASE (CONSISTING OF INGS 2 & 3))
Fraction by Wt: 75-85%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:COPPER (SARA 313) (CERCLA)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 50-65%
OSHA PEL:0.1MG/M3 FUME;1 DUST
ACGIH TLV:0.2 MG/M3 FUME
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ZINC (SARA 313) (CERCLA)
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: 15-30%
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PROPELLANT (CONSISTING OF INGS 5 - 7)
Fraction by Wt: 7-13%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:NITROCELLULOSE
CAS:9004-70-0
RTECS #:QW0970000
Fraction by Wt: 7-13%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:NITROGLYCERIN (NG) (SARA 313) (CERCLA)
CAS:55-63-0
RTECS #:QX2100000
Fraction by Wt: 0.5-2%
OSHA PEL:0.2 MG/M3, S, C
ACGIH TLV:0.05 PPM, S
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:PHTHALIC ACID, DIBUTYL ESTER; (DIBUTYL PHTHALATE) (SARA
313) (CERCLA)
CAS:84-74-2
RTECS #:TI0875000
Fraction by Wt: 0.5-2%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:PRIMER; (PRIMING MIX/PRIMER (CONSISTING OF INGS 9 - 12))
Fraction by Wt: 4-7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:COPPER (SARA 313) (CERCLA)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 0-5%
OSHA PEL:0.1MG/M3 FUME;1 DUST
ACGIH TLV:0.2 MG/M3 FUME
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ZINC (SARA 313) (CERCLA)
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: 0-2%
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:LEAD STYPHNATE
CAS:15245-44-0
Fraction by Wt: 0-1%
OSHA PEL:0.05 MG/M3 (MFR)
ACGIH TLV:0.15 MG/M3 (MFR)
Ingred Name:BARIUM (II) NITRATE (1:2)
CAS:10022-31-8
RTECS #:CQ9625000
Fraction by Wt: 0-1%
OSHA PEL:5 MG/M3 (BA)
ACGIH TLV:2 MG/M3 (BA)
Ingred Name:NON-HAZARDOUS INGREDIENTS; (PAPER WAD)
Fraction by Wt: 0.5-2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:IRRIT MAY OCCUR W/INFLAMM OF CONJ. ANY EFT WOULD NOT
RSLT IN PERM IMPAIRMENT OF VISION. INGEST:IRRIT TO (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:GI TRACT. ADDNL EFTS WOULD BE SIMILAR TO ACUTE
INHAL. CHRONIC:NO ADDNL EFTS ARE KNOWN/HAVE BEEN REPORTED (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:EXCEPT THOSE DESCRIBED FOR ACUTE EXPOSURES. LEAD IS
CLASSIFIED AS A CARCIN BY IARC (MFR). NOTE:LEAD (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:APPEARS ON NAVY LIST OF OCCUP CHEM REPRO HAZS. SEEK
CONSULTATION FROM APPROP HLTH PROFESSIONALS (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:CONCERNING LATEST HAZARD LIST INFO & SAFE HANDLING &
EXPOSURE INFO .
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:SOURCES, NO FLARES, SMOKING/FLAMES IN HAZ AREA.
PLACE IN PROPER DOT CNTNR FOR LATER DISPOSITION. DISP(ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19:OF PER GUIDELINES UNDER WASTE DISP. NO EXTRA PROT
REQD BEYOND THAT LISTED IN PERSONAL PROT EQUIP SECTION.(ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20:REPORTABLE QUANTITY (PER 40 CFR 302.4) - AS
NITROGLYCERIN: 10 LBS; DIBUTYL PHTHALATE: 10 LBS.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH:DEACTIVATION. CARE MUST BE TAKEN TO PVNT
ENVIRON CONTAM FROM USE OF THIS MATL. USER OF THIS MATL(ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22:HAS RESPONSIBILITY TO DISP OF UNUSED MATL, RESIDUES
& CNTNRS IN COMPLIANCE W/ALL RELEVANT LOC, STATE & (ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23:FEDERAL LAWS & REGULATIONS REGARDING TREATMENT,
STORAGE & DISPOSAL FOR HAZARDOUS & NONHAZARDOUS WASTES.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROD IS COMPOSED OF FINISHED CARTRIDGE
& PROPELLANT IS COMPLETELY SEALED. PHYSICAL NATURE OF PROD MAKES
ABSORPTION FROM ANY RTE UNLIKELY. SM AMT OF INHALABLE PARTICLES MAY
BE CREATED WHEN CARTRIDGE IS FIRED. ACUTE:INHAL:PROPELLANT IS
IRRITTO NOSE, MOUTH, THROAT & LUNGS. DILATION OF BLOOD VESSELS W/
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:DROP IN BLOOD PRESS & HDCH, CYANOSIS &
MENTAL CONFUSN MAY RSLT FROM NITROGLYCERIN. HDCH MAY BE SEV & CAN
REMAIN FOR FEW HRS TO SEVERAL DAYS. IT TYPICALLY STARTS AT FOREHEAD
PROCEEDED BY SENSA TION OF WARMTH & FULLNESS IN HEAD & MAYEXTEND TO
BACK OF NECK. NAUS, VOMIT & ABDOM PAIN MAY ALSO OCCUR. SKIN:
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE KNOWN OR REPORTED.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . EYES:IMMEDIATELY FLUSH
W/POTABLE WATER FOR A MINIMUM OF 15 MINUTES, SEEK ASSISTANCE FROM
MD. SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD .
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . DO NOT FIGHT FIRE IF FIRE REACHES CARGO. USE WATER FROM
UNMANNED STATION.
Unusual Fire/Explosion Hazard:EXPLOSIVE. EVACUATE ALL PERSONS INCLUDING
EMERGENCY RESPONSE PERSONNEL FROM AREA FOR 1500 FEET (1/2 MILE) IN
ALL DIRECTIONS IF FIRE REACHES CARGO.
================== Accidental Release Measures ==================
Spill Release Procedures:FOR ALL TRANSPORTATION ACCIDENTS, CALL
CHEMTREC AT 800-424-9300. SPILL MITIGATION PROCS:PROD DOES
REPRESENT EXPLO HAZ WHEN INVOLVED IN FIRE/EXPOS TO HEAT, FRICTION,
SHOCK, ETC. REMOVE ALL SOURCES OF I GNIT. LAND SPILL:SHUT OFF ALL
IGNIT (ING 19)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT TAKE INTERNALLY. AVOID CONTACT
W/SKIN, EYES & CLOTHING. STORE IN COOL, DRY, WELL VENTILATED PLACE,
AWAY FROM ALL SOURCES OF IGNITION.
Other Precautions:DO NOT SUBJECT TO MECH SHOCK. SHELF LIFE LIMITATIONS:
25-30 YEARS. INCOMPAT MATLS FOR STOR/TRANSPORT:ACIDS, CLASS A & B
EXPLOSIVES & OXIDIZERS. PROT CONCERNS MUST ALSO ADDRESS POTNTL OF
PHYSICAL CHARA CT OF THIS PROD AS EXPLOSIVE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NONE REQUIRED FOR NORMAL HANDLING.
Ventilation:NONE BEYOND NORMAL VENTILATION.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . NONE NORMALLY REQUIRED.
Work Hygienic Practices:UPON CONTACT W/SKIN OR EYES, WASH OFF W/WATER.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:22,25,27,32,38 CALIBER POWERTOOL ROUND.
CNDTNS(STAB):SEVERELY DAMAGED. AVOID CARTRIDGES PLACED IN HIGH
RADIO FREQUENCY ENERGY FIELD (RADAR STATIONS). EFTS OF OVEREXP:MAY
CAUSE IRRIT WHICH WOULD SUBSIDE RAPIDLY UPONREMOVAL OF MATL W/OUT
PERM DMG. ADDNL EFTS SIMILAR TO ACUTE INHAL. EYE: (ING 14)
================== Physical/Chemical Properties ==================
Appearance and Odor:CYLINDRICAL, BRASS CARTRIDGE; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS & CAUSTICS.
Stability Condition to Avoid:MECH SHOCK/IMPACT & ELEC (STATIC)
DISCHARGE:BASED ON PRIMER. CARTRIDGE MAY DETONATE IF CASE IS
PUNCTURED/ (SUPP DATA)
Hazardous Decomposition Products:NITROGEN OXIDES, CARBON MONOXIDE,
CARBON DIOXIDE, LEAD OXIDES, LEAD DUST/FUME.
==================== Disposal Considerations ====================
Waste Disposal Methods:IF PROD BECOMES WASTE, IT MEETS CRITERIA OF HAZ
WASTE AS DEFINED UNDER 40 CFR 261 - EPA HAZ WASTE #D003. IF PROD
BECOMES WASTE, IT WILL BE HAZ WASTE SUBJECT TO LAND DISP
RESTRICTIONS UNDER 40 CFR 268 & MUST BE MANAGED ACCORDINGLY.
OTHER: (ING 22)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:68 1002 D-5604 VAPO-DUSTER
Preparer's Name:SAIFI RANIWALA
CAGE:0GUK5
CAGE:0GUK5
============= Composition/Information on Ingredients =============
Ingred Name:CHLORODIFLUOROMETHANE
CAS:75-45-6
RTECS #:PA6390000
= Wt:100.
ACGIH TLV:3540 MG/M3;1000 PPM
Ozone Depleting Chemical:2
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: HARMFUL, MAY CAUSE
IRREGULARITIES/DEATH. INTENTIONAL MISUSE CAN BE FATAL. SKIN: LIQUID
CAN CAUSE FROSTBITE, BURNING SENSATION/IRRITATION. EYES: MILD
IRRITANT, BLURRING OF VISION. INGESTION : REPEATED EXPOSURE MAY
CAUSE SLIGHT LIVER EFFECTS & SLIGHT DECREASE IN RATE OF WEIGHT
GAIN.
Explanation of Carcinogenicity:NOT LISTED.
Effects of Overexposure:HEART IRREGULARITIES, UNCONSCIOUSNESS,
FROSTBITE, IRRITATION, DISCOMFORT, TEARING, BLURRING OF VISION,
WEIGHT GAIN
Medical Cond Aggravated by Exposure:INDIVIDUALS W/PREEXISTING DISEASES
OF THE CENTRAL NERVOUS/CARDIOVASCULAR SYSTEM.
======================= First Aid Measures =======================
First Aid:INHALATION: IMMEDIATELY REMOVE TO FRESH AIR. KEEP PERSON
CALM. GIVE CPR/OXYGEN IF NECESSARY. SKIN: FLUSH W/WATER. TREAT FOR
FROSTBITE IF NEEDED. EYES: IMMEDIATELY FLUSH W/PLENTY OF COLD
WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:USE STANDARD FIREFIGHTING TECHNIQUES TO FIGHT
FIRES INVOLVING THIS MATERIAL. THE MATERIAL ITSELF IS
NON-FLAMMABLE. USE EXTINGUISHING MEDIA APPROPRIATE FOR COMBUSTIBLES
IN AREA.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR & WILL
COLLECT IN LOW AREAS & OTHER CONFINED AREAS. CONTENTS UNDER
PRESSURE MAY EXPLODE IF HEATED ABOVE 120F.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. DON'T FLUSH TO SEWERS. REMOVE
OPEN FLAMES. USE SELF CONTAINED BREATHING APPARATUS FOR LARGE
SPILLS.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE >120F. DON'T STORE/USE
NEAR HEAT, SPARKS/FLAMES. STORE OUT OF REACH OF CHILDREN. FOR
PROFESSIONAL USE ONLY. TO BE USED ONLY BY THOSE PERSONS WHO HAVE
BEEN PROPERLY TRAINED TO USE THIS PROD UCT & INSTRUCTED IN ITS SAFE
HANDLING.
Other Precautions:DON'T BREATHE VAPORS. DON'T GET IN EYES/ON SKIN.
DON'T TAKE INTERNALLY. NOTE TO PHYSICIANS: BECAUSE OF POSSIBLE
DISTURBANCE OF CARDIAC RHYTHM, CATECHOLAMINE DRUGS, SUCH AS
EPINEPHRINE SHOULD BE USED W /SPECIAL CAUTION IN SITUATIONS OF
EMERGENCY LIFE SUPPORT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE SELF CONTAINED BREATHING APPARATUS IF
WORKING IN AN AREA W/EXTREMELY HIGH VAPOR CONCENTRATION.
Ventilation:LOCAL/MECHANICAL TO KEEP BELOW EXPOSURE LIMITS OF
INGREDIENTS.
Work Hygienic Practices:USE GOOD HYGIENIC PRACTICES WHEN DEALING W/THIS
PRODUCT. USE IN WELL VENTILATED AREA.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:=-41.1C, -42.F
Vapor Density:>1
Spec Gravity:1.2
Evaporation Rate & Reference:FASTER THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS W/SLIGHT ETHEREAL ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALI, ALKALINE EARTH METALS; POWDERED ALUMINUM, ZINC, BERYLIUM
Stability Condition to Avoid:OPEN FLAMES, HIGH TEMPERATURES, HEAT,
SPARKS, OTHER IGNITION SOURCES
Hazardous Decomposition Products:HYDROCHLORIC & HYDROFLUORIC ACIDS,
CARBONYL HALIDES AT HIGH TEMPERATURES
==================== Disposal Considerations ====================
Waste Disposal Methods:RECLAIM BY DISTILLATION/REMOVE TO A PERMITTED
WASTE FACILITY. DISPOSE OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL
REGULATIONS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:595-15056 BLUE
CAGE:OO159
CAGE:OO159
============= Composition/Information on Ingredients =============
Ingred Name:PIGMENTS PER REQUIRED COLOR & FILLER
Fraction by Wt: 14%
Ingred Name:POLYVINYL CHLORIDE RESIN & PHTHALATE ESTER PLASTICIZER.
Fraction by Wt: 84%
Ingred Name:BA CD STABILIZERS & WAX MOLD RELEASE AGENT.
Fraction by Wt: 1%
===================== Hazards Identification =====================
Effects of Overexposure:EYE/SKIN: IRRITATION. VAPORS: RESP TRACT
IRRITATION.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH WITH WATER 15 MINUTES OR UNTIL IRRITATION
SUBSIDES. SKIN: WASH WITH SOAP AND WATER. INHALATION: REMOVE TO
FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point:425F/218C (TOC)
Extinguishing Media:DRY CHEM,FOAM OR WATER SPRAY (FOAM & WATER CAUSE
FROTH)
Fire Fighting Procedures:WATER SPRAY TO COOL FIRE EXPOSED SURFACES.
Unusual Fire/Explosion Hazard:APPLIED NET OF WATER OR FOAM TO BURNING
MATERIAL WILL CAUSE VIOLENT FROTHING FUMES,SMOKE & CO.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP PUBLIC AWAY,SHUT OFF SOURCE. PREVENT
LIQUID FROM ENTERING SEWERS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE. DO NOT STORE NEAR FLAME OR HEAT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN.
Ventilation:LOCAL/MECHANICAL
Supplemental Safety and Health
MFR ADDRESS: DEPOT STREET,WILKINSENVILLE,MA 01590
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:446F/230C
Vapor Pres:1.3
Solubility in Water:NEGLIGIBLE
Appearance and Odor:MILD ESTER ODOR.
Percent Volatiles by Volume:0-4
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS,NITRIC ACID.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTAIN SPILLED LIQIUD WITH SAND. RECOVER BY
PUMPING OR WITH SUITABLE ABSORBENT. COMPLY WITH LOCAL,STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-P-27401
CAGE:36346
CAGE:36346
============= Composition/Information on Ingredients =============
Ingred Name:NITROGEN, LIQ
RTECS #:QW9720000
Fraction by Wt: 100%
===================== Hazards Identification =====================
Effects of Overexposure:SKIN CNTCT CAUSES FREEZING. LG AMTS VAPOR CAN
CAUSE RAPID SUFFOCATION BY OXYGEN DEPLETION.
======================= First Aid Measures =======================
First Aid:INH: MOVE TO FRESH AIR. SKIN: RESTORE TISSUE TO NORMAL TEMP
RAPIDLY. WARMING CAN BE DONE BY USING WARM WATER AT 108F. DO NOT
USE WATER ABOVE 112F. DO NOT RUB OR MASSAGE FROZEN PARTS. PROT
INJURED TISS UE FROM INFECTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:NON FLAMMABLE
Fire Fighting Procedures:EVACUATE PERSONNEL, DELUGE CNTNRS W/WATER
Unusual Fire/Explosion Hazard:DO NOT DISCHARGE WATER SPRAYS INTO LIQ
NITROGEN
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE PERSONNEL. ALLOW LIQ TO EVAPORATE.
TEST AREA FOR SUFFICIENT OXYGEN IF SPILLED IN CONFINED SPACE.
======================Handling and Storage ======================
Other Precautions:DO NOT GET LIQ IN EYES, ON SKIN/CLOTHING
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELF-CNTND BRTHNG APPARATUS WHERE NEEDED
Ventilation:DILUTION VENT NORM ADEQUATE
Other Protective Equipment:HIGH-TOPPED SHOES, CUFFLESS TROUSERS
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:G3
Boiling Pt:B.P. Text:-320.4F
Vapor Density:0.97
Evaporation Rate & Reference:HIGH
Solubility in Water:NO
Appearance and Odor:COLORLESS, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IAW ALL LOCAL, STATE, FED REG
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TILE & GROUT CLEANER SL-7 SUPER CLEANUP
CAGE:PRDCH
CAGE:PRDCH
============= Composition/Information on Ingredients =============
Ingred Name:PHOSPHORIC ACID
CAS:7664-38-2
RTECS #:TB6300000
Fraction by Wt: 0-10%
OSHA PEL:1 MG/M3;3 STEL
ACGIH TLV:1 MG/M3;3 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:GLYCOLIC ACID; (HYDROXYACEDIC ACID)
CAS:79-14-1
RTECS #:MC5250000
Fraction by Wt: 0-10%
Ingred Name:GLYCOLS,POLYETHYLENE,MONO(P-NONYLPHENYL) ETHER; (NONIONIC
SURFACTANT)
CAS:26027-38-3
RTECS #:MD0906000
Fraction by Wt: 0-10%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 100%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MAY CAUSE SEVERE EYE IRRITATION.
PROLONGED CONTACT MAY CAUSE PERMANENT EYE DAMAGE. SKIN: MAY CAUSE
SEVERE SKIN IRRITATION. PROLONGED CONTACT MAY CAUSE BURNS, REDNESS.
INHAL:MAY BE IRRITATING TOMUCOUS MEMBRANES IN NOSE, THROAT,
LUNGS, CHOKING, COUGHING, HEADACHE MAY OCCUR. INGEST:MAY CAUSE
IRRIT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:TO THE INTESTINE, MOUTH, THROAT, AND
ESOPHAGUS. VOMITING AND DIARRHEA EXPECTED WITH LARGE DOSES.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15 MIN.
CONSULT PHYS. SKIN: FLUSH WITH LARGE AMOUNTS OF WATER. REMOVE
CONTAMINATED CLOTHES. SEEK MED ATTN. INHAL: SEEK FRESH AIR, O*2 IF
REQUIRED. INGEST: DO NOT INDUCE VOMIT OR GIVE ANYTHING BY MOUTH.
IMMED SEEK MED ATTN.
===================== Fire Fighting Measures =====================
Extinguishing Media:NON FLAMMABLE. MEDIA SUITABLE FOR SURROUNDING FIRE
.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
================== Accidental Release Measures ==================
Spill Release Procedures:MOP OR ABSORB FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN. FOR
INDUSTRIAL & COMMERCIAL USE & STORAGE BY TRAINED PERSONS ONLY.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ADEQUATE VENTILATION.
Ventilation:AS REQUIRED TO MAINTAIN TLV.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:20@68F
Spec Gravity:1.10
pH:1.00
Evaporation Rate & Reference:1-1 (H*2O=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIQUID/CHARACTERISTIC ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES/BLEACH.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:ACIDIC VAPORS IN FIRE.
==================== Disposal Considerations ====================
Waste Disposal Methods:SEWER OR INCINERATE WITH LOCAL, FEDERAL, AND
STATE APPROVAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:OOPS!, 710834
CAGE:TO137
CAGE:TO137
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE, O-CHLORO-; (MONOCHLOROTOLUENE (MIXED ISOMERS))
CAS:95-49-8
RTECS #:XS9000000
< Wt:7.
ACGIH TLV:259 MG/M3;50 PPM
Ingred Name:ETHYL ALCOHOL
CAS:64-17-5
RTECS #:KQ6300000
< Wt:12.
OSHA PEL:1900 MG/M3;1000 PPM
ACGIH TLV:1880 MG/M3;1000 PPM
Ingred Name:XYLENE (MIXED ISOMERS)
CAS:1330-20-7
RTECS #:ZE2100000
> Wt:21.
ACGIH TLV:434 MG/M3;100 PPM
ACGIH STEL:651 MG/M3;150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:LIGHT ALIPHATIC SOLVENT NAPHTHA (PETROLEUM). VM & P NAPTHA
CAS:64742-89-8
> Wt:58.
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO AREA FREE OF VAPORS & SUPPORT/RESTORE
BREATHING. SEEK MEDICAL
ATTENTION IMMEDIATELY. INGEST: DO NOT INDUCE VOMITING! IF VOMITING
SPONTANEOUSLY
OCCURS, KEEP VICTIM'S HEAD BELOW THE HIP S TO PREVENT ASPIRATION INTO
LUNGS.
SEEKMEDICAL ATTENTION IMMEDIATELY. EYES: FLUSH WITH WATER FOR AT LEAST
15 MINUTES.
SEEK MEDICAL ATTENTION IMMEDIATELY. SKIN: REMOVE CONTAMINATED CLOTHING
& WASH
AFF ECTED AREA WITH SOAP & WATER. DO NOT REUSE CONTAMINATED ARTICLES.
SEEK MEDICAL
ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:=10.C, 50.F
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:KEEP CONTAINERS COOL WITH WATER. PRESSURE
BUILD-UP COULD RESULT IN CONTAINER RUPTURE. VAPOR IS HEAVIER THAN
AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:FOR LG SPILLS, EVACUATE HAZ AREA OF
UNPROTECTED PERS. WEAR APPROP NIOSH APPRVD RESP
& PROT CLTHG. SHUT OFF SOURCE OF LEAK IF SAFE TO DO SO. DIKE & CNTN. IF
VAP CLOUD FORMS,
WATER FOG MAY BE USED TO SU PPRESS. CNTN RUN-OFF. REMOVE W/VACUUM
TRUCKS/PUMP TO
STOR/SALVAGE VESSELS. SOAK UP RESIDUE W/ABSORB SUCH AS CLAY, SAND/OTHER
SUITABLE MATL.
PLACE IN NON-LEAKING CNTNRS. SEAL TIGHTLY FOR PROPER DISP.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP PRODUCT CONTAINERS COOL, DRY &
AWAY FROM SOURCES OF IGNITION. USE & STORE
W/ADEQUATE VENT IN PROPERLY LABELED, CLOSED CONTAINERS. AVOID
INHALATION OF VAPORS
& SKIN CONTACT. DO NOT TAKE INTERNALLY .
Other Precautions:DISPOSAL CONTAINERS MUST BE SEALED TIGHTLY & PROPERLY
LABELED. DO NOT EAT, DRINK OR
SMOKE IN WORK AREA. WASH HANDS THORUGHLY OUGHLY AFTER USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURE EXCEEDS, TLV, USE NIOSH APPROVED
RESPIRATOR.
Ventilation:USE EXPLOSION-PROOF VENTILATION AS REQUIRED TO CONTROL
VAPOR CONCENTRATIONS.
Other Protective Equipment:EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA .
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER USE. BEFORE
DRINKING, EATING OR SMOKING.
Supplemental Safety and Health
BP: 22.8C,73F (REPRESENTS LOWEST BOILING OF INDIVIDUAL RAW MATERIALS).
SPEC GRAV: 6.627 POUND PER GALLON (WATER =1)
================== Physical/Chemical Properties ==================
Boiling Pt:=22.8C, 73.F
B.P. Text:SUPDAT
Vapor Density:>1 (AIR=1)
Spec Gravity:0.79
Evaporation Rate & Reference:<1 (ETHER =1)
Solubility in Water:INSOLUBLE
Appearance and Odor:THIN COLORED LIQUID/SOLVENT WITH SWEET PERFUME
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CHLORINATED COMPOUNDS AND OXIDIZING MATERIALS.
Stability Condition to Avoid:HEAT, HOT SURFACES AND ALL SOURCES OF
IGNITION.
Hazardous Decomposition Products:CHLORINE GAS, HCL & OTHER CHLORINATED
CMPDS, CARBON DIOXIDE, CARBON MONOXIDE & UNIDENTIFIED ORGANICS MAY
BE FORMED DURING COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT FLUSH INTO SEWERS OR WATERWAYS. DISPOSE
OF IN ACCORDANCE WITH LOCAL, COUNTY,
STATE AND FEDERAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:HAZARD CLASS: ORM-D. DOT SHIPPING NAME: CONSUMER
COMMODITY. UN NUMBER: N/A. OTHER: THE ORM-D CLASSIFICATION APPLIES
TO CONTAINERS UNDER ONE GALLON IN SIZE AND IS NOT APPLICABLE TO AIR
SHIPMENT.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TRISODIUM PHOSPHATE ANHYDROUS FOOD GRADE
CAGE:76541
CAGE:76541
============= Composition/Information on Ingredients =============
Ingred Name:PHOSPHORIC ACID, TRISODIUM SALT; (SODIUM PHOSPHATE,
TRIBASIC)
CAS:7601-54-9
RTECS #:TC9490000
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SUPDAT: MATL & PLACE IN CONTRS. IF POSS, COMPLETE CLEANUP
ON A DRY BASIS. AFTER ALL PRACTICAL DRY CLEANUP HAS (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2:BEEN DONE, RESIDUAL CONTAM CAN BE FLUSHED WITH PLENTY
OF WATER.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT)4,150 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CAUSES BURNS TO EYES. CAUSES
IRRITATION TO EYES AND SKIN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IMMED FLUSH WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES. CALL A PHYSICIAN. SKIN: IMMED FLUSH WITH PLENTY OF WATER.
REMOVE CONTAMD CLTHG. WASH CLOTHING BEFORE REUSE. INHAL: REMOVE TO
FRESH AIR.SUPPORT BRTHG (GIVE O*2/ARTF RESP) . INGEST: CALL MD
IMMED .
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:SODIUM PHOSPHATE, TRIBASIC, AS CURRENTLY
DEFINED, IS A HAZ SUBSTANCE UNDER COMPREHENSIVE ENVIRON RESPONSE,
COMPENSATION & LIABILITY ACT (CERCLA). IF 5,000 LBS/MORE ARE REL
INTO ENVIRON, IT MUST BE RE PORTED TO NATL RESPONSE CTR
(800-424-8802/(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT GET IN EYES, ON SKIN/CLTHG.
AVOID BRTHG DUST. KEEP CONTR CLSD. USE W/ADEQ VENT.
Other Precautions:EMPTIED CONTAINER RETAINS VAP AND PRODUCT RESIDUE.
OBSERVE ALL LABELED SAFEGUARDS UNTIL CONTAINER IS CLEANED,
RECONDITIONED OR DESTROYED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED EQUIPMENT WHEN AIRBORNE
EXPOSURE IS EXCESSIVE. CONSULT RESPIRATOR MFR TO DETERMIN
APPROPRIATE TYPE EQUIPMENT FOR GIVEN APPLICATN.
Ventilation:PROVIDE VENTILATION TO MINIMIZE EXPOSURE. LOCAL EXHAUST
VENTILATION PREFERRED.
Other Protective Equipment:HAVE EYE BATHS IMMED AVAIL WHERE EYE CONT
CAN OCCUR. PROTECTIVE CLOTHING TO PVNT SKIN CONT.
Work Hygienic Practices:LAUNDER CONTAMD CLTHG AND CLEAN PROTECTIVE
EQUIPMENT BEFORE REUSE.
Supplemental Safety and Health
PH: 11.9(1% SOLN@25C). MATL TO AVOID: FREE OF WATER BECAUSE OF ITS
CORROSIVITY WHEN WET. SPILL PROC: 202-426-2675). SINCE LOC, ST, &
FED LAWS MAY VARY, CONSULT YOUR ATTORNEY/APPROP REGULATORY OFFICIAL
S FOR INFO RELATING TO SPILL REPORTING.SWEEP, SCOOP/VACUUM UP ALL
SPILLED MATL, CONTAMD SOIL & OTHER CONTAMD (ING 2)
================== Physical/Chemical Properties ==================
pH:SUPDAT
Solubility in Water:14.5@25C
Appearance and Odor:WHITE, FREE-FLOWING, GRANULAR PRODUCT; ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
TRISODIUM PHOSPHATE ANHYDROUS COULD BE CORR TO ALUMINUM SURF BECAUSE OF
HIGH PH. SEALED CONTRS SHOULD BE KEPT (SUPDAT)
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A LANDFILL I/A/W ALL APPLICABLE
LOCAL, STATE, AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:184 5650,INDUSTREX DEVLPR REPL, PART-B
Kit Part:Y
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:ACETIC ACID (SARA III)
CAS:64-19-7
RTECS #:AF1225000
Fraction by Wt: 85-90%
OSHA PEL:10 PPM
ACGIH TLV:10 PPM/15 STEL; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:1-PHENYL,3-PYRAZOLIDONE DERIVATIVE
CAS:92-43-3
RTECS #:UQ8750000
Fraction by Wt: 5-10%
Other REC Limits:NONE ESTABLISHED
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEE "OVEREXPOSURE SYMPTOMS"
Effects of Overexposure:EYES,SKIN,MUCOUS MEMBRANES:SEVERE & RAPID
BURNS; INGEST:PAIN,VOMIT;INHALE:SHORT BREATH,COUGH,FATAL.
Medical Cond Aggravated by Exposure:DYES/SKIN:FLUSH WITH LARGE AMOUNTS
OF WATER AT LEAST 15 MINUTES; INHALE:REMOVE TO FRESH AIR,KEEP CALM;
INGEST:RINSE MOUTH,DRINK EXCESS WATER,DO NOT INDUCE VOMIT. GET
IMMEDIATE MEDICAL ATTENTION FOR EY
======================= First Aid Measures =======================
First Aid:EYES/SKIN:FLUSH WITH LARGE AMOUNTS OF WATER AT LEAST 15
MINUTES; INHALE:REMOVE TO FRESH AIR,KEEP CALM; INGEST:RINSE
MOUTH,DRINK EXCESS WATER,DO NOT INDUCE VOMITING. GET
IMMEDIATELMEDICAL ATTENTION FOR EYES,INGEST,INHALE, OR SKINBURNS.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:103F/39C
Extinguishing Media:WATER, CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED AIR SUPPLIED
RESPIRATOR.
Unusual Fire/Explosion Hazard:CONTAINERS MAY EXPLODE IN HEAT OF FIRE.
ACID SOLUTION:AVOID PHYSICAL CONTACT. USE WATER TO SPRAY AND COOL
CONTAINERS.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. NEUTRALIZE
WITH BAKING SODA(SODIUM BICARBONATE)
Neutralizing Agent:NONE STATED.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA; PROTECT FROM PHYSICAL DAMAGE & AVOID CONTACT WITH SKIN(ACID
SOLUTION). AVOID CONTACT WITH ALKALIES.
Other Precautions:REMOVE & WASH CONTAMINATED CLOTHING. MAINTAIN STRICT
HYGIENE. STORE IN LOW FIRE RISK AREA ALSO.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE AN APPROPRIATE NIOSH-APPROVED RESPIRATOR FOR
ORGANIC ACID VAPOR SHOULD BE WORN IF NEEDED.
Ventilation:LOCAL EXHAUST RECOMMENDED; USE GENERAL MECHANIC VENTILATION
AT LEAST TEN AIR CHANGES PER HOUR.
Supplemental Safety and Health
KEY1:F6. PART B OF A 3 PART KIT.
================== Physical/Chemical Properties ==================
HCC:F6
Boiling Pt:B.P. Text:>212F/100C
Vapor Pres:15
Vapor Density:1.83
Spec Gravity:1.07
pH:2
Solubility in Water:COMPLETE
Appearance and Odor:AMBER TO RED BROWN LIQUID, STRONG VINEGAR ODOR.
Percent Volatiles by Volume:91
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID ALKALIES. MAY REACT WITH METALS AND FORM HYDROGEN.
Stability Condition to Avoid:VAPOR GENERATING CONDITIONS; IGNITION
SOURCES, AVOID TEMPERATURE ABOVE 100F.
Hazardous Decomposition Products:NONE STATED. BUT VAPORS FROM PRODUCT
ARE NOXIOUS.
==================== Disposal Considerations ====================
Waste Disposal Methods:ABSORB MATERIAL IN VERMICULITE OR OTHER SUITABLE
ABSORBENT AND PLACE IN IMPERVIOUS CONTAINER. DISPOSE IN INCINERATOR
EQUIPPED WITH AFTERBURNER AND SCRUBBER OR CONTRACT WITH LICENSED
CEHMICAL WASTE DIS POSAL SERVICE.
| 1 | gloves_mandatory |
=======================================================
Product ID: 52833, DERUSTO RUST PREVENTATIVE ENAMEL (SUPP DATA)
Cage: 90300
Box: 277
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 90300
Box: 277
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:EYE CONT:MAY CAUSE IRRIT. SKIN CONT:COMPONENT OF
THIS PROD IN ITS CONCENTRATED STATE IS KNOWN TO CAUSE MOD IRRIT AFTER PRLNG
&/OR RPTD CONT. INHAL:VAP HARMFUL. VAP MAY IRRIT NOSE & UPPER RESP TR
ACT. VAP INHAL MAY AFFECT BRAIN/NERV SYS CAUSING DIZZ, HDCH/NAUS. INGEST:THIS
MATL MAY BE HARMFUL/FATAL(EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:IF SWALLOWED. IF INGESTED THIS
PROD MAY CAUSE VOMIT, DIARR & DEPRESSED RESP. ASPIR OF MATL INTO LUNGS
DUE TO VOMIT CAN CAUSE CHEM PNEUM WHICH CAN BE FATAL. CHRONIC:RPTS HAVE ASSOC
PERM BRAIN & NERV SYS DMG W/PRLNG & RPTD OCCUP OVEREXP TO SOLVS.
PRLNG/RPTD CONT W/SKIN CAN CAUSE DEFAT WHICH MAY LEAD TO
Medical Cond Aggravated By Exposure: NONE KNOWN.
First Aid: EYES:FLUSH W/LARGE QUANTITIES OF WATER UNTIL IRRITATION SUBSIDES
(FOR AT LEAST 15 MINUTES). SKIN:IMMEDIATELY WASH W/SOAP & WATER. CONTACT
MD IF IRRITATION DEVELOPS. INHAL:REMOVE TO FRESH AIR. CONTACT MD
IMMEDIATELY. INGEST:DO NOT INDUCE VOMITING. CONTACT MD OR REGIONAL POISON
CONTROL CENTER IMMEDIATELY.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: DIKE SPILL AREA. ABSORB REMAINING LIQUID W/ABSORBENT
MATERIAL & PLACE INTO CONTAINERS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISP OF ACCORDING TO FED, STATE & LOC STDS.
DISCARDED MATL SHOULD BE INCIN AT PERMITTED FACILITY. LIQS CANNOT BE DISPOSED
OF IN A LANDFILL. DO NOT REUSE EMPTY CNTNR. STATE & LOC REGS/RESTRICTIONS
ARE COMPLEX & MAY DIFFER FROM FED REGS. (SUPP DATA)
Handling And Storage Precautions: KEEP OUT OF REACH OF CHILDREN. AVOID SKIN
& EYE CONTACT. AVOID BREATHING VAPORS. USE ONLY IN A WELL VENTILATED
AREA.
Other Precautions: STORE AWAY FROM CAUSTICS & OXIDIZERS. KEEP CONTAINERS
TIGHTLY CLOSED WHEN NOT IN USE. KEEP CONTAINERS FROM EXCESSIVE HEAT &
FREEZING. DO NOT STORE AT TEMPERATURES >120F. DO NOT TAKE INTERNALLY.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: SCC
Flash Point Text: 105F,41C
Extinguishing Media: CO*2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). COOL EXPOSED CONTAINERS W/WATER.
Unusual Fire/Explosion Hazard: COMBUST LIQ. CAN FORM EXPLO MIXTS AT TEMPS
AT/ABOVE FLASHPOINT. CNTNRS MAY EXPLODE IF EXPOS TO EXTREME HEAT. ELIM
SOURCES OF IGNIT:HEAT, ELEC EQUIP, (SUPP DATA)
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF 8 HR EXPOS LIM/VALUE IS EXCEEDED FOR ANY COMPONENT,
USE A NIOSH APPRVD RESP. CONSULT YOUR SAFETY EQUIP SUPPLIER & OSHA REG,
29 CFR 1910.134 FOR RESP REQUIREMENTS. A RESP PROT PROGRAM THAT MEETS OSH A
1910.134 & ANSI Z88.2
Ventilation: PROVIDE SUFFICIENT MECH VENT (LOC/GEN EXHST) TO MAINTAIN EXPOS
BELOW PEL & TLV. VAPS ARE HVR/AIR & WILL COLLECT
Other Protective Equipment: ANSI APPROVED EYE WASH FOUNTAIN & DELUGE SHOWER (FP
N). PROVIDE IMPERVIOUS APRON IF BODY CONTACT W/PRODUCT IS EXPECTED.
Work Hygienic Practices: WASH CONTAMINATED CLOTHING BEFORE REUSE. AVOID
PROLONGED OR REPEATED CONTACT W/SKIN.
Supplemental Safety and Health: NOTE:USER'S OF "L" VERSION SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). MFR'S TRADE NAME/PART NO:VOC BRUSH GRADE.
EXPLO HAZ:SPKS & FLAMES. DO NOT PUT IN CONT W/OXIDIZING OR CAUSTIC MATLS.
WASTE DISP METH:RESPONSIBILITY FOR PROPER WASTE DISP IS W/OWNER OF WASTE.
EPA WASTE CODE-IF DISCARDED (40 CFR 261): IGNITABLE.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >240F,>116C
Vapor Pres: 15 @ 38C
Vapor Density: HVR/AIR
Spec Gravity: 0.94-1.14
VOC Grams/Liter: 340
Evaporation Rate & Reference: FASTER THAN BUTYL ACETATE
Solubility in Water: NEGLIGIBLE
Appearance and Odor: LIQUID, VARIOUS COLORS; PETROLEUM ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: EXCESSIVE HEAT & FREEZING.
Materials To Avoid: STRONG OXIDIZERS & CAUSTICS.
Hazardous Decomposition Products: NORMAL DECOMPOSITION PRODUCTS, I.E., CO*X,
NO*X.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: VOLATILE ORGANIC COMPOUNDS:330-340 G/L (29-36%) - LESS
WATER, LESS EXEMPT SOLVENT & MATERIAL.
=======================================================
HAZCOM Label
=======================================================
Product ID: 52833, DERUSTO RUST PREVENTATIVE ENAMEL (SUPP DATA)
Cage: 90300
Company Name: DAP INC.
PO Box: 277
Zipcode: 45401-0277
Label Required IND: Y
Date Of Label Review: 08/13/1998
Status Code: C
Label Date: 08/13/1998
Origination
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUST. ACUTE:EYE CONT:MAY CAUSE IRRIT. SKIN
CONT:COMPONENT OF THIS PROD IN ITS CONCENTRATED STATE IS KNOWN TO CAUSE MOD
IRRIT AFTER PRLNG &/OR RPTD CONT. INHAL:VAP HARMFUL. VAP MAY IRRITATE
NOSE & U PPER RESP TRACT. VAP INHAL MAY AFFECT BRAIN/NERV SYS CAUSING
DIZZ, HDCH/NAUS. INGEST:THIS MATL MAY BE HARMFUL/FATAL IF SWALLOWED. MAY
CAUSE VOMIT, DIARR & DEPRESSED RESPIRATION. ASPIR HAZ - MAY BE FAT AL.
CHRONIC:ANIMAL STUDIES CLEARLY DEMONSTRATED DOSE-RELATED ADVERSE EFTS ON CNS,
BLOOD-FORMING TISSUES, BLOOD, KIDNEYS & LIVER, ASSOC W/ADMIN OF
2-BUTOXYETHANOL (FP N). POSS PERM BRAIN & NERV SYS DMG . SKIN DEFAT,
DERM. MISUSE MAY BE HARMFUL/FATAL.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BIO-RAD BLOOD GAS CONTROL C-570-I LEVEL 1
CAGE:TO489
CAGE:TO489
============= Composition/Information on Ingredients =============
Ingred Name:INORGANIC BUFFERS (CONTAINING NO HAZARDOUS INGREDIENTS)
Ingred Name:INORGANIC SALTS
Ingred Name:DEIONIZED WATER
Ingred Name:CARBON DIOXIDE (CO*2)
CAS:124-38-9
RTECS #:FF6400000
OSHA PEL:9000 MG/M3;5000 PPM
ACGIH TLV:9000 MG/M3;5000 PPM
ACGIH STEL:54000 MG/M3
Ingred Name:NITROGEN (N2)
CAS:7727-37-9
RTECS #:QW9700000
Ingred Name:OXYGEN (O*2)
CAS:7782-44-7
RTECS #:RS2060000
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:NOT HARMFUL.
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN: WASH
WELL WITH SOAP AND WATER. IF SKIN IS BROKEN OR MATERIAL ENTERS AN
OPEN WOUND, GET MEDICAL ATTENTION. INGESTION: FLUSH MOUTH WITH
WATER, WITHOU T SWALLOWING. GET MEDICAL ATTENTION. INHALATION:
INHALATION: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) .
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SELF CONTAINED BREATHING
APPARATUS AND FULL PROTECTIVE EQUIPMENT . NOT CONSIDERED TO BE A
FIRE AND EXPLOSION HAZARD.
Unusual Fire/Explosion Hazard:NOT CONSIDERED TO BE A FIRE AND EXPLOSION
HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:DON PROTECTIVE GEAR. CAREFULLY WIPE UP SPILLS
WITH ABSORBENT PAPER AND THOROUGHLY CLEANSE AREA WITH SOAP AND
WATER. DISPOSE OF ALL CLEANING MATERIALS, USED PIPET TIPS, SYRINGES
AND CONTAINERS IN ACCO RDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE COMPONENTS AT ROOM TEMPERATURE.
Other Precautions:DO NOT PIPET ANY SOLUTION BY MOUTH. GLASS AMPULES ARE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:USE LOCAL EXHAUST IF NECESSARY TO MAINTAIN EXPOSURE BELOW
TLV .
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER . AVOID DIRECT CONTACT BY USING PROPER PROTECTIVE ARTICLES:
Work Hygienic Practices:DO NOT EAT, DRINK, SMOKE OR APPLY COSMETICS IN
THE LABORATORY.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:=100.C, 212.F
Appearance and Odor:CLEAR, DYED LIQUID.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:0013117A MOSPRAYCO APPLICANCE WHITE
Preparer's Name:JULIE HOAGLAND
CAGE:88633
CAGE:88633
============= Composition/Information on Ingredients =============
Ingred Name:HYDROCARBONS, C3-4, LIQUIFIED PETROLEUM GAS
CAS:68476-40-4
Fraction by Wt: 30%
ACGIH TLV:1000 PPM
Ingred Name:BENZIN, NAPHTHA, MINERAL SPIRITS, PETROLEUM NAPHTHA
CAS:8030-30-6
RTECS #:DE3030000
Fraction by Wt: 15%
Other REC Limits:STEL 400 PPM
OSHA PEL:100 PPM
ACGIH TLV:300 PPM
Ingred Name:TITANIUM DIOXIDE, TIO2 (SUSPECTED ANIMAL CARCINOGEN BY IARC
- GROUP 3) *94-2*
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 10%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 18%
Other REC Limits:375 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 11%
OSHA PEL:2400 MG/CUM
ACGIH TLV:750 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: ANESTHETIC/IRRITATION OF
THE RESPIRATORY TRACT/NERVOUS SYSTEM DEPRESSION. SKIN: MODERATE
IRRITATION/DERMATITIS/SENSITIZER/ABSORPTION. EYES: SEVERE
IRRITATION/SENSITIZER. INGESTION: GI IRRI TATION. ASPIRATION INTO
THE LUNGS DURING INGESTION/VOMITING MAY CAUSE MILD-SEVERE PULMONARY
INJURY, POSSIBLY DEATH.(SUPP
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, STAGGERING
GAIT, CONFUSION, UNCONSCIOUSNESS, COMA, ASPHYXIATION, DEFATTING,
REDNESS, TEARING BLURRED VISION, NAUSEA, VOMITING, DIARRHEA.
Medical Cond Aggravated by Exposure:PRE-EXISTING DERMATITIS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. ADMINISTER OXYGEN IF
BREATHING IS DIFFICULT. RESTORE BREATHING IF NECESSARY. TREAT
SYMPTOMATICALLY. SKIN: WASH W/SOAP & WATER. EYES: FLUSH IMMEDIATELY
W/LARGE AMOUNTS OF WATER FOR 15 MINS. INGESTION: DRINK 1-2 GLASSES
OF WATER TO DILUTE. DON'T INDUCE VOMITING. ASPIRATION HAZARD.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:-134F
Lower Limits:0.8
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS
USED, FOG NOZZLES ARE PREFERABLE. WATER MAY BE USED TO COOL CLOSED
CONTAINERS WHEN EXPOSED TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:CONTENTS UNDER PRESSURE. AT TEMPS >120F
CONTAINERS MAY VENT, RUPTURE/BURST. PROTECT PERSONNEL. ISOLATE FROM
IGNITION SOURCES & AVOID APPLICATION TO HOT SURFACE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. (FLAME, HOT
SURFACES, & ELECTRICAL, STATIC/FRICTIONAL SPARKS). AVOID BREATHING
VAPORS. VENTILATE AREA. CONTAIN & REMOVE W/INERT ABSORBENT &
NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE >120F. STORE LARGE
QUANTITIES ONLY IN BUILDINGS DESIGNED TO COMPLY W/OSHA. KEEP
CLOSURES TIGHT & CONTAINER UPRIGHT & CLOSED AFTER EACH USE
Other Precautions:DON'T STORE/USE NEAR HEAT, SPARKS/FLAME. DON'T PLACE
AEROSOL CAN IN TRASH COMPACTOR. DON'T PUNCTURE. DON'T TRANSFER TO
UNLABELED CONTAINERS. DON'T HANDLE UNTIL SAFETY PRECAUTIONS HAVE
BEEN READ & UNDE RSTOOD. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:OPEN AREAS USE NIOSH/MSHA APPROVED MECHANICAL
FILTER RESPIRATOR FOR AIRBORNE PARTICLES. IN RESTRICTED AREAS USE
NIOSH/MSHA APPROVED CHEMICAL-MECHANICAL FILTERS FOR PARTICULATE,
GAS & VAPOR. CONFINED: NIOSH/MSHA APPROVED AIR LINE TYPE HOODS.
Ventilation:ALL APPLICATION AREAS SHOULD BE VENTILATED IN ACCORDANCE TO
OSHA REGULATIONS.
Other Protective Equipment:SIDE SHIELDS, PROTECTIVE OUTER-WEAR
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH SKIN THOROUGHLY. AVOID BREATHING VAPORS & CONTACT
W/EYES & SKIN.
Supplemental Safety and Health
HEALTH HAZ CONT'D: REPORTS HAVE ASSOCIATED REPEATED/PROLONGED
OCCUPATIONAL OVEREXPOSURE TO SOLVENTS W/PERMANENT BRAIN & NERVOUS
SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING &
INHALI NG THE CONTENTS MAY BE HARMFUL/FATAL.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:-13F-228F
Vapor Density:>1
Spec Gravity:0.8
Evaporation Rate & Reference:FASTER THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TYPICAL PAINT W/SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS
Stability Condition to Avoid:HIGH TEMPERATURES, TEMPS >120F, HEAT,
SPARKS/FLAME
Hazardous Decomposition Products:FUMES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS. INCINERATE IN APPROVED FACILITY. DON'T
INCINERATE CLOSED CONTAINERS.
| 1 | gloves_mandatory |
=======================================================
Product ID: GUARDEX SOLUTION 9
Cage: GO170
Box: 67
=======================================================
Contractor Summary
=======================================================
Cage: GO170
Box: 67
Cage: 87892
Box: 6549
=======================================================
Ingredients
=======================================================
Cas: 497-19-8
RTECS #: VZ4050000
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: NONE SPECIFIED BY MANUFACTURER. CHRONIC: NONE
KNOWN.
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES: FLUSH W/WATER FOR AT LEAST 15 MIN. GET MED ASSIST IF SYMP
PERSIST. SKIN: FLUSH W/(1:4) VINEGAR SOLN & THEN FRESH WATER. INGEST: IF
SWALLOWED, CALL MD IMMED. DO NOT INDUCE VOMIT. IF CONSCIOUS, GI VE LGE AMTS
OF DILUTE (1:4) VINEGAR, LEMON, ORANGE/GRAPEFRUIT JUICE. FOLLOW W/MILK/RAW
EGG WHITES BEATEN IN WATER. INHAL: REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE
OXYGEN/ARTF RESP) (FP N).
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: FLUSH TO SEWER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: FLUSH TO SEWER. DISPOSE OF IN ACCORDANCE W/LOCAL, STATE
& FEDERAL REGULATIONS (FP N).
Handling And Storage Precautions: THE HAZ ING IN THIS SOLN IS VERY DILUTE &
IS UNLIKELY TO PRODUCE HAZ CNDTNS LISTED. AVOID CONT W/SKIN & EYES. PROT
FROM FREEZING & EXTREME HEAT.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: WATER.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT REQUIRED. USE NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN (FP N).
Ventilation: PROVIDE ADEQUATE LOCAL EXHAUST IF MISTING OCCURS.
Other Protective Equipment: NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Physical/Chemical Properties
=======================================================
Solubility in Water: COMPLETE
Appearance and Odor: COLORLESS, ODORLESS LIQUID
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HIGH TEMPERATURES.
Materials To Avoid: ACIDS.
Hazardous Decomposition Products: NONE SPECIFIED BY MANUFACTURER.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: GUARDEX SOLUTION 9
Cage: GO170
Assigned IND: Y
Company Name: HYDROTECH
PO Box: 67
Zipcode: 30031
Label Required IND: Y
Date Of Label Review: 05/10/1995
Status Code: C
Label Date: 05/10/1995
Origination Code: G
Skin Protection IND: YES
Signal Word: NONE
Respiratory Protection IND: YES
Health Hazard: None
Contact Hazard: None
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: AVOID EYE AND SKIN CONTACT. ACUTE: NONE SPECIFIED BY
MANUFACTURER. CHRONIC: NONE KNOWN.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AX0765 ACID RED 1
CAGE:EO656
CAGE:63612
CAGE:EO656
============= Composition/Information on Ingredients =============
Ingred Name:AMIDO NAPHTHOL RED G
CAS:3734-67-6
RTECS #:QJ6030000
Fraction by Wt: 100%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE IRRITATING ON CONTACT W/SKIN,
EYES/MUCOUS MEMBRANES.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
======================= First Aid Measures =======================
First Aid:SKIN: WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH THOROUGHLY
W/WATER FOR 15 MINS. INHALATION: REMOVE TO FRESH AIR. GIVE CPR IF
NEEDED. INGESTION: IF CONSCIOUS, DRINK WATER & INDUCE VOMITING.
NEVER GIV E ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR SCBA.
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCES HIGHLY
TOXIC FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR SUITABLE PROTECTIVE
EQUIPMENT. ELIMINATE IGNITION SOURCES. CONTAIN/RELEASE & ELIMINATE
ITS SOURCE, SAFELY W/O RISK. TAKE UP & CONTAINERIZE FOR PROPER
DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED & PROTECTED FROM
PHYSICAL DAMAGE. STORE IN A WELL VENTILATED AREA AWAY FROM STRONG
OXIDIZERS.
Other Precautions:DON'T GET IN EYES, SKIN/CLOTHING. DON'T BREATHE DUST.
DN'T TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Ventilation:FUME HOOD/ADEQUATE
Other Protective Equipment:PROTECTIVE CLOTHING, EYE WASH & SAFETY
EQUIPMENT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. HANDLE W/CARE
IN KEEPING W/SAFE LABORATORY PRACTICES IS RECOMMENDED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:COMPLETE
Appearance and Odor:RED POWDER
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:SULFUR OXIDES, NITROGEN OXIDES, CARBON
OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AT A PERMITTED WASTE DISPOSAL SITE,
IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DTIC DOME
CAGE:MILES
CAGE:MILES
CAGE:0ASR7
============= Composition/Information on Ingredients =============
Ingred Name:DACARBAZINE (SUSPECTED HUMAN & ANIMAL CARCINOGEN BY IARC,
NTP)
CAS:4342-03-4
RTECS #:NI3950000
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: NAUSEA, VOMITING,
DIARRHEA, DECREASE APPETITE. SKIN: RASH.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:INHALATION: MUSCLE & OR JOINT ACHES, DECREASED
WHITE & RED CELLS OF HAIR, LIVER DAMAGE.
Medical Cond Aggravated by Exposure:PATIENTS W/DEPRESSED WHITE &/OR RED
BLOOD CELLS DUE TO CANCER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER. SKIN: DUST OFF. WASH W/WATER. TREAT BONE
MARROW FAILURE & LIVER FAILURE. FOLLOW TEST OF BLOOD CELLS & LIVER
FUNCTION. IF FILTRATED USE ICE BAG. OBTAIN MEDICAL ATTENTION IN ALL
CAS ES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:MAY DECOMPOSE EXPLOSIVELY >250C/482F.
================== Accidental Release Measures ==================
Spill Release Procedures:COLLECT SOLIDS, ABSORB LIQUIDS & CONTAINERIZE.
======================Handling and Storage ======================
Handling and Storage Precautions:TREAT AS A DRUG ITEM PER LABEL
DIRECTIONS. HANDLE ONLY BY THOSE FAMILIAR W/INJECTABLE DRUG
ADMINISTRATION. USE CAUTION OF INADVERTENT NEEDLE STICKS.
Other Precautions:AVOID BREATHING DUST. AVOID SKIN CONTACT W/LIQUID.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DUST MASK (3M 8710). OR HEPA FILTER CARTRIDGE
RESPIRATOR.
Ventilation:MECHANICAL, PREPARE IN VERTICAL FLOW HOOD
Other Protective Equipment:EQUIPMENT NECESSARY TO KEEP OFF SKIN.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:APPRECIABLE
Appearance and Odor:OFF-WHITE COLORED POWDER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:EXTREME HEAT
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CHROMIUM OXIDE
CAGE:FO994
CAGE:FO994
CAGE:67027
============= Composition/Information on Ingredients =============
Ingred Name:CHROMIUM (III) OXIDE (2:3)
CAS:1308-38-9
RTECS #:GB6475000
Fraction by Wt: 100%
OSHA PEL:0.5 MG/M3 (CR)
ACGIH TLV:0.5 MG/M3 (CR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:MAY CAUSE SNEEZING, COUGHING,
DIFFICULTY BRTHG & SERIOUS IRRIT TO MUC MEMB OF RESP TRACT.
SKIN:MAY CAUSE IRRIT, ITCHING, INFLAMM & DERM. EYE:MAY CAUSE
BURNING SENSATION, IRRIT, REDNESS & WATERIN G OF EYES IF COMES IN
CONTACT. OTHER:CORROSIVE ACTION ON SKIN & MUC MEMB. LESIONS ARE
CONFINED TO EXPOS(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:PARTS, AFFECTING CHIEFLY SKIN OF HANDS
& FOREARMS & MUC MEMB OF NASAL SEPTUM. SMALL ULCERS, ABOUT THE SIZE
OF MATCH HEAD/END OF LEAD PENCIL MAY BE FOUND, CHIEFLY AROUND BASE
OF NAILS, ON KNUC KLES, DORSUM OF HANDS & FOREARMS. THEY HEAL
SLOWLY & LEAVE SCARS. ON MUC MEMB OF NASAL SEPTUM ULCERS ARE
USUALLY(SUPDAT)
Medical Cond Aggravated by Exposure:RESPIRATORY DISORDERS.
======================= First Aid Measures =======================
First Aid:INGEST:GIVE 1-2 CUPS OF MILK OR WATER & INDUCE VOMITING. SEEK
IMMEDIATE MEDICAL ATTENTION. INHAL:REMOVE TO FRESH AIR; GIVE OXYGEN
IF BREATHING IS DIFFICULT. SEEK MEDICAL ATTENTION. SKIN: BRUSH OFF
SKI N, WASH AREA W/SOAP & WATER & SEEK MEDICAL ATTENTION. EYES:
FLUSH W/LUKEWARM WATER FOR AT LEAST 15 MINUTES & SEEK MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE DRY CHEMICAL, CO2.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:WHEN HEATED TO DECOMPOSITION, IT MAY EMIT
TOXIC FUMES OF CR & CROX.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT CLTHG.
ISOLATE AREA WHERE SPILL OCCURRED & INSURE THAT PROPER VENT IS
AVAIL. VACUUM UP SPILL USING HIGH EFFICIENCY UNIT & PLACE IN CNTNR
FOR PROPER DISP. TAKE C ARE NOT TO RAISE DUST.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN TIGHTLY CLOSED CONTAINERS IN
A COOL, DRY PLACE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED DUST-MIST-FUME
CARTRIDGE RESPIRATOR.
Ventilation:LOCAL EXHAUST: MAINTAIN EXPOSURE BELOW TLV FOR CR. HANDLE
IN DRY, CONTROLLED ENVIRONMENT.
Other Protective Equipment:WEAR PROTECTIVE CLOTHING TO PREVENT
CONTAMINATION OF SKIN & CLOTHES.
Work Hygienic Practices:WASH HANDS & FACE THOROUGHLY AFTER HANDLING &
BEFORE MEALS.
Supplemental Safety and Health
HMIS(LEVIEN) NOTES THAT THIS ITEM IS LISTED AS
IARC-3(TUMORIGEN,MUTAGEN).MP:4111F,2266C +/- 25. EFTS OF OVEREXP:
ACCOMPANIED BY PURULENT DISCHARGE & CRUSTING. CHROMATE SALTS ARE
EXPTL & HUMAN CARCINS OF LUNGS, NASAL CAVITY & PARANASAL SINUS,
ALSO EXPTL CARCINS OF STOMACH & LARYNX.
================== Physical/Chemical Properties ==================
HCC:T6
Boiling Pt:B.P. Text:7232F,4000C
Melt/Freeze Pt:M.P/F.P Text:SUPP DATA
Spec Gravity:5.21
Solubility in Water:INSOLUBLE
Appearance and Odor:GREEN CRYSTALLINE POWDER; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & STRONG BASES.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CR & CROX.
Conditions to Avoid Polymerization:HEAT, FLAME & INCOMPATIBLE
MATERIALS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W APPLICABLE FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:200 FLUID, 100 CS
CAGE:58149
CAGE:58149
============= Composition/Information on Ingredients =============
Ingred Name:SILICONE
CAS:63148-62-9
Code:F
RTECS #:JT6484500
= Wt:100.
Code:F
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Health Hazards Acute and Chronic:EYES:DIRECT CONTACT MAY CAUSE
TEMPORARY DISCOMFORT WITH MILD REDNESS & DRYNESS SIMILAR TO
WINDBURN. SKIN:A SINGLE PROLONGED EXPOSURE (24-48 HOURS) CAUSES NO
KNOWN ADVERSE EFFECT. INHALATION:NO IRRITA TION TO EYES &
RESPIRATORY PASSAGES. NO INJURY IS LIKELY FROM RELATIVELY SHORT
EXPOSURE OF LESS THAN 8 HOURS. ORAL:SMALL AMOUNTS TRANSFERRED TO
THE MOUTH BY FINGERS DURING USE, ETC. SHOULD NOT INJURE.
SWALLOWING LARGE AMOUNTS MAY CAUSE DIGESTIVE DISCOMFORT. CHRONIC:
NO KNOWN ADVERSE CHRONIC EFFECTS. MAY ENHANCE ALLERGIC RESPONSES IN
CERTAIN PERSONS.
Effects of Overexposure:EYES:DIRECT CONTACT MAY CAUSE TEMPORARY
DISCOMFORTWITH MILD REDNESS & DRYNESS SIMILAR TO WINDBURN. SKIN:A
SINGLE PROLONGED EXPOSURE (24-48 HOURS) CAUSES NO KNOWN ADVERSE
EFFECT. INHALATION:NO IRRITA TION TO EYES & RESPIRATORY PASSAGES.
NO INJURY IS LIKELY FROM RELATIVELY SHORT EXPOSURE OF LESS THAN 8
HOURS. ORAL:SMALL AMOUNTS TRANSFERRED TO THE MOUTH BY FINGERS
DURING USE, ETC. SHOULD NOT INJURE. SWALLOWING LARGE AMOUNTS MAY
CAUSE DIGESTIVE DISCOMFORT.
Medical Cond Aggravated by Exposure:MANUFACTURER STATES THAT THEY DO
NOT KNOW OF ANY MEDICAL CONDITIONS THAT MIGHT BE AGGRAVATED BY
EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH IMMEDIATELY WITH WATER. SKIN:WIPE OFF AND FLUSH
WITH WATER. INHALATION:NO FIRST AID SHOULD BE NEEDED. ORAL:NO FIRST
AID SHOULD BE NEEDED.
===================== Fire Fighting Measures =====================
Flash Point Method:OC
Flash Point:=315.6C, 600.F
Extinguishing Media:CARBON DIOXIDE (CO2), WATER, WATER FOG, DRY
CHEMICAL, FOAM.
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING SHOULD BE WORN IN FIGHTING FIRES INVOLVING
CHEMICALS.
Unusual Fire/Explosion Hazard:NONE KNOW.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT MATERIAL TO COLLECT AND CONTAIN
FOR SALVAGE OR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE REASONABLE CARE AND CAUTION.
Other Precautions:NO KNOWN ADVERSE CHRONIC HEALTH EFFECTS, BUT
UNNECESSARY EXPOSURE TO ANY CHEMICAL SHOULD BE AVOIDED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO RESPIRATORY PROTECTION SHOULD BE NEEDED.
SUITABLE RESPIRATOR: NONE SHOULD BE NEEDED.
Ventilation:LOCAL EXHAUST AND/OR MECHANICAL/GENERAL VENTILATION
RECOMMENDED.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASHING AT MEALTIME AND END OF SHIFT IS
ADEQUATE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Pres:AT 77F/25C LESS THAN 5MM
Spec Gravity:0.98
Evaporation Rate & Reference:N/D
Solubility in Water:<0.1% NEGLIGIBLE
Appearance and Odor:VERY LITTLE ODOR, LIQUID, NO COLOR
Percent Volatiles by Volume:<5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL CAN CAUSE A REACTION.
Hazardous Decomposition Products:SILICONE DIOXIDE, CARBON DIOXIDE AND
TRACES OF INCOMPLETELY BURNED CARBON PRODUCTS.
=================== Toxicological Information===================
Toxicological Information:NONE SPECIFIED BY MANUFACTURER.
===================== Ecological Information =====================
Ecological:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:ALL LOCAL, STATE AND FEDERAL REGULATIONS
CONCERNING HEALTH AND POLLUTION SHOULD BE REVIEWED TO DETERMINE
APPROVED DISPOSAL PROCEDURES.
=================== MSDS Transport Information ===================
Transport Information:NONE SPECIFIED BY MANUFACTURER.
===================== Regulatory Information =====================
Federal Regulatory Information:DOT/EPA SPILL REPORTING INFORMATION:
HAZARDOUS SUBSTANCE: NONE. REPORTABLE QUANTITY: NOT APPLICABLE.
CONCENTRATION OF HAZARDOUS SUBSTANCE: NOT APPLICABLE. REPORTABLE
QUANTITY OF PRODUCT: NOT APPLICABL E.
State Regulatory Information:NONE SPECIFIED BY MANUFACTURER.
======================= Other Information =======================
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:SLOW DRY AQUEOUS RECORDER INK, PURPLE
CAGE:17405
CAGE:17405
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIUM, (4-(P-(DIMETHYLAMINO)-ALPHA-(P-(ETHYL
(M-SULFOBENZYL)AMINO)PHENYL)BENZYLIDE NE) (ING 2)
CAS:1694-09-3
RTECS #:BQ1140000
Fraction by Wt: 0.5-1.5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ING 1:-2,5-YCLOHEXADIEN-1-YLIDENE)ETHYL(M- SULFOBENZYL)-,
HYDROXIDE, INNER SALT, SODIUM SALT; (C.I. ACID VIOLET 49, DYE)
RTECS #:9999999ZZ
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: <99.5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:NON-HAZARDOUS INGREDIENTS (% WT:98.5-99.5)
Fraction by Wt: <99.5%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT) >5 GM/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:SKIN:CAN CAUSE IRRITATION AND
SKIN STAINING. EYES:CONTACT MAY CAUSE IRRITATION.
INHALTION:INHALATION OF VAPORS MAY RESULT IN RESPIRATORY
IRRITATION. INGESTION:MAY RESULT IN GASTRIC DISTURBANCE.
CHRONIC:NONE LISTED BY MANUFACTURER.
Explanation of Carcinogenicity:C.I. ACID VIOLET 49:IARC MONOGRAPHS,
SUPPLEMENT, VOL 7, PG 56, 1987:GROUP 2B. ANIMAL:SKIN.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WATER FOR AT LEAST 15 MINS. IF IRRIT PERSISTS,
GET PROMPT MED ATTN. SKIN:REMOVE CONTAMD CLTHG & WASH SKIN THORO
W/SOAP & WATER. INHAL:REMOVE PERSON TO FRESH AIR. AID BRTHG IF
NECESSARY & G ET MED ATTN. INGEST:DILUTE W/WATER AND INDUCE
VOMITING. GET MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NOT FLAMMABLE
Extinguishing Media:USE MEDIA PROPER TO PRIMARY CAUSE OF FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CARBON MONOXIDE, ACROLEIN.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE STAINS WITH SOAPY WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED ORGANIC VAPOR RESPIRATOR, IF
VAPORS OR MIST ARE GENERATED.
Ventilation:MECHANICAL (GENERAL) VENTILATION IS SATISFACTORY.
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPEC GRAV:1.075-1.105 (H*2O=1). VP:DUE TO H*2O ONLY. VAP DENS:DUE TO
H*2O ONLY.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:-15F,-26C
Vapor Pres:SUPDAT
Vapor Density:SUPDAT
Spec Gravity:SUPDAT
pH:4-8
Evaporation Rate & Reference:DUE TO H*2O ONLY
Solubility in Water:COMPLETE
Appearance and Odor:PURPLE LIQUID, SLIGHT CHARACTERISTIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTS WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:DECOMPOSES AT TEMPERATURES ABOVE 290C.
Hazardous Decomposition Products:ACROLEIN.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE DISPOSAL SHOULD BE IN ACCORDANCE WITH
EXISTING FEDERAL, STATE, AND LOCAL ENVIRONMENTAL CONTROL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AC-3
Preparer's Name:C.L. RUSSELL
CAGE:TRIMA
CAGE:TRIMA
============= Composition/Information on Ingredients =============
Ingred Name:ASPHALT FUMES, ASPHALT, CUTBACK ASPHALT
CAS:8052-42-4
RTECS #:CI9900000
Fraction by Wt: 100%
Other REC Limits:5 MG/M3
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN/INGESTION: IRRITATION &
BURN. INHALATION: NASAL & RESPIRATORY IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES/SKIN/INGESTION: IRRITATION & BURN.
INHALATION: NASAL & RESPIRATORY IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS. SKIN:
WASH W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. GIVE CPR OR
OXYGEN IF NEEDED. INGESTION: ONLY INDUCE VOMITING IF INSTRUCTED BY
PHYSICIAN . NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:425F
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, FOAM & CO2
Fire Fighting Procedures:WATER OR FOAM MAY CAUSE FROTHING. USE WATER TO
KEEP FIRE-EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:COMBUSTIBLE LIQUID.
================== Accidental Release Measures ==================
Spill Release Procedures:BUILD DIKE TO CONTAIN LIQUID. ALLOW TO COOL &
PLACE IN CONTAINER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT W/EYES, SKIN, CLOTHING &
BREATHING OF FUMES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:HALF-MASK DUST, FULL-FACE DUST RESPIRATOR OR
SUPPLIED RESPIRATORS. IF CONCENTRATION IS >250 MG/CUM, WEAR
SELF-CONTAINED BREATHING APPARATUS W/POSITIVE PRESSURE.
Ventilation:LOCAL OR DILUTION
Other Protective Equipment:LONG-SLEEVED SHIRT & CUFFLESS TROUSERS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING. WASH
THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:0.90
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK CEMENTIOUS MATERIAL W/ASPHALT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:HEAT
Hazardous Decomposition Products:CO & SMOKE
==================== Disposal Considerations ====================
Waste Disposal Methods:RECYCLE OR INCINERATE IN ACCORDANCE W/LOCAL,
STATE & FEDERAL REGULATIONS. COMBUSTIBLE LIQUID
| 1 | gloves_mandatory |
=======================================================
Product ID: DEEP STRIP
Cage: IO718
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 0TMN6
Cage: IO718
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: CORR TO ALL BODY TISSUES. HARMFUL SKIN CONT MAY NOT
CAUSE IMMED PAIN. CHRONIC: NONE KNOWN. INHAL OF MISTS MAY CAUSE IRRIT TO
NOSE, THROAT, & MUC MEMB, TISSUE DAM, & PULM IRRIT. INGEST: HARMFUL/
FATAL. MAY CAUSE DISCOMFORT, NAUS, VOMIT, & SEV TISSUE DAM TO MOUTH,
ESOPHAGUS, STOM, & TO OTHER (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ: TISSUES. CORR TO MOUTH, THROAT
& STOM. SKIN: CONT MAY CAUSE SEV IRRIT, DERM, & CHEM BURNS. CORR.
EYES: CONT MAY CAUSE TEAR, SEV IRRIT, BURNING, VISION LOSS, & BLINDNESS.
TARGET ORGANS: EYES , SKIN, RESP SYS. ANIMAL STUDIES HAVE CLEARLY
DEMONSTRATED DOSE-RELATED ADVERSE EFTS ON CNS, HEMATOPOIETIC (SUPDAT)
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INGEST: DO NOT INDUCE VOMIT. IF CONSCIOUS & CAN SWALLOW,
ADMINISTER MILK/WATER. SKIN: REMOVE CONTAMD CLOTHES, FLOOD W/WATER FOR 15
MIN. EYES: FLOOD W/LUKEWARM (NOT HOT) WATER POURED FROM A LG GLASS 2- 3
INCHES FROM EYES. REMOVE CONTACTS. HAVE PATIENT BLINK AS MUCH AS POSS WHILE
FLOODING EYES. CONTINUE FOR @ LST 15 MIN. INHAL: MOVE TO FRESH AIR. GIVE ARTF
RESP IF PATIENT IS NOT BRTHG. (SUPDAT)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: WEAR PROPER PROT EQUIP INCL RUBB BOOTS. STOP LEAK IF
YOU CAN DO SO W/OUT RISK. DIKE/DAM LG SPILLS. VENT AREA IF NEEDED. SOAK UP
W/SAND/OTHER NON-COMBUST INERT ABSORB MATLS. FLUSH AREA W/WATER & FOLLOW
W/NORM CLEAN-UP PROC. KEEP COMBUST AWAY!
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: COMPLY W/ALL FED, ST, & LOC REGS. CONSULT STATE
& LOCAL AUTHORITIES FOR RESTRICTIONS ON DISPOSAL OF CHEMICAL WASTE. IF
APPROVED, MAY BE DILUTED AND DRAINED TO A MUNICIPAL SEWER/WASTE TRTMT PLANT.
RINS E EMPTY CONTR THORO W/WATER BEFORE DISCARDING.
Handling And Storage Precautions: FOLLOW ALL LBL DIREC. INSTRUCT PERS ABOUT
PROPER USE, HAZS, PREC, & FIRST AID MEASURES. AVOID INHAL, INGEST &
CONT W/SKIN & EYES.
Other Precautions: ROTATE REGULARLY. HANDLE CAREFULLY TO AVOID DAMAGING
CONTAINER. KEEP CONTAINER CLOSED WHEN NOT IN USE. RECOMMENDED STORAGE
TEMPERATURE BELOW 100F. KEEP OUT OF CHILDREN'S REACH.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: 145F,63C
Extinguishing Media: FOR FIRES IN AREA, USE APPROPRIATE MEDIA. FOR EXAMPLE:
WATER SPRAY, DRY CHEMICAL, CARBON DIOXIDE/ALCOHOL FOAM.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N). EVAC AREA OF UNPROTECTED PERS.
Unusual Fire/Explosion Hazard: PRODUCT MAY REACT W/SOME METALS SUCH AS
ALUMINUM, ZINC, TIN, ETC, TO RELEASE FLAMMABLE HYDROGEN GAS.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE REQUIRED WITH NORMAL USE. USE NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN (FP N).
Ventilation: GEN MECH: SATIS. MAINTAIN ADEQ VENT. KEEP LEVELS BELOW RECOMM TLV.
LOC EXHST: NOT ORD NEEDED. AVOID INHAL OF
Other Protective Equipment: WEAR FULL-COVER PROTECTIVE CLOTHING TO PREVENT
REPEATED OR PROLONGED CONTACT. EMER EYE BATH & DELUGE SHOWER (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: USERS OF "L" VERSION OF SHOULD CONSULT "LR"
VERSION FOR MORE INFO (FP N). MATL TO AVOID: FLAMM HYDROGEN GAS. EFTS OF
OVEREXP: TISSUE, BLOOD, KIDNEYS & LIVER ASSOC W/ADMIN OF ETHYLENE GLYCOL
MONOB UTYL ETHER (EGBE). (EXTRACTED FROM DHHS(NIOSH) PUB # 90-118) (FP N).
FIRST AID PROC: ADMIN FIRST AID TRTMT AS
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 1.035(H*2O=1)
PH: >12.5
Solubility in Water: COMPLETE
Appearance and Odor: YELLOW LIQUID WITH CHARACTERISTIC ODOR
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: AVOID MIXING W/ANY OTHER CLEANING PROD. MIX ONLY
W/WATER. DO NOT STORE @ HIGH TEMPS. RECOMM STOR TEMP
Materials To Avoid: ACIDIC MATLS, ORG CHEMS, & VARIOUS METALS (ALUMINUM,
MAGNESIUM, ZINC, TIN, BRASS/BRONZE) WHICH CAN GENERATE (SUPDAT)
Hazardous Decomposition Products: MIXING W/INCOMPATIBLE MATERIALS MAY PRODUCE
HYDROGEN, CARBON MONOXIDE, CARBON DIOXIDE, & OTHER TOX & IRRITATING FUMES.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: DEEP STRIP
Cage: IO718
Assigned IND: Y
Company Name: U.S. CHEMICAL
Street: 316 HART ST
Zipcode: 53094
Label Required IND: Y
Date Of Label Review: 03/02/1994
Status Code: C
Label Date: 03/02/1994
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Severe
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: CORROSIVE. AVOID ALL CONTACT. STORE BELOW 100F. ACUTE:
INHALATION OF MIST MAY CAUSE IRRITATION TO NOSE, THROAT AND MUCOUS MEMBRANES,
TISSUE DAMAGE AND PULMONARY IRRITATION. INGESTION IS HARMFUL/FATAL. MAY
CAUSE DISCOMFORT, NAUSEA, VOMITINGAND SEVERE TISSUE DAMAGE TO MOUTH,
ESOPHAGUS, STOMACH AND OTHER TISSUES. SKIN CONTACT MAY CAUSE SEVERE
IRRITATION, DERMATITIS, CHEMICAL BURNS. EYE CONTACT MAY CA USE TEARING,
SEVERE IRRITATION, BURNING, VISION LOSS AND BLINDNESS. CHRONIC: ANIMAL
STUDIES HAVE DEMONSTRATED DOSE RELATED ADVERSE EFFECTS TO CNS, BLOOD FORMING
TISSUE, BLOOD, LIVER AND KIDNEYS ASSOC W/ADMIN OF 2-BUTOXYETHANOL (FP N).
=======================================================
| 1 | gloves_mandatory |
=======================================================
Product ID: AVIATION ORANGE VINYL ACRYLIC, PNT NP O5
Cage: 0ACJ7
Box: 2000
=======================================================
Contractor Summary
=======================================================
Cage: 0ACJ7
Box: 2000
=======================================================
Ingredients
=======================================================
Cas: 1314-13-2
RTECS #: ZH4810000
% Wt: 2.93
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST
------------------------------
Cas: 1317-65-3
RTECS #: EV9580000
% Wt: 14.67
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST
------------------------------
Cas: 1318-94-1
% Wt: 4.89
OSHA PEL: 20 MPPCF (MFR)
ACGIH TLV: 3 MG/M3 (MFR)
------------------------------
Cas: 107-21-1
RTECS #: KW2975000
% Wt: 1.36
OSHA PEL: N/K (FP N)
ACGIH TLV: C 50 PPM,VAPOR
EPA Rpt Qty: 1 LB
DOT Rpt Qty: 1 LB
------------------------------
Cas: 127087-87-0
% Wt: 0.97
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHALATION:VAPORS OR MISTS CAN CAUSE HEADACHE, NAUSEA, AND
IRRITATION OF THE NOSE, THROAT AND LUNGS. SKIN CONTACT:IRRITATING TO THE SKIN
UPON REPEATED OR PROLONGED CONTACT. EYE CONTACT:IRRITATING TO E YES.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: PERSONS WITH SEVERE EYE, NOSE, THROAT,
LUNG AND SKIN CONDITIONS SHOULD AVOID USE.
First Aid: INHALAITON:MOVE SUBJECT TO FRESH AIR, USE RESUSCITATION IF
NECESSARY. EYES:FLUSH WITH A LARGE AMOUNT OF WATER FOR AT LEAST 15 MINUTES.
SEE A PHYSICIAN IF IRRITATION PERSISTS. SKIN:WASH AFFECTED SKIN A REAS WITH
SOAP AND WATER. INGESTION:IF SWALLOWED DILUTE BY GIVING 2 GLASSES OF WATER TO
DRINK. SEE PHYSICIAN. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: KEEP SPECTATORS AWAY. FLOOR MAY BE SLIPPERY; USE CARE
TO AVOID FALLING. DIKE & CNTN SPILL WITH INERT MATERIAL (E.G., SAND,
EARTH). TRANSFER LIQUID TO CNTNRS FOR DISP. KEEP SPILLS & CLEANING
RUNOFFS OU T OF MUNICIPAL SEWERS AND OPEN BODIES OF WATER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: COAGULATE EMULSION BY STEPWISE ADDN OF FERRIC CHLORIDE
& LIME. REMOVE CLEAR SUPERNATANT LIQ & FLUSH TO CHEM SEWER. INCIN
SOLIDS & CONTAM DIKING MATL AT PERMITTED FACILITY ACCORD TO LOC, STATE
& FED RE GS.
Handling And Storage Precautions: KEEP FROM FREEZING, PRODUCT MAY COAGULATE.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NON-COMBUSTIBLE
Extinguishing Media: WATER FOG, ALCOHOL RESISTANT FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: MATERIAL CAN SPLATTER ABOVE 100C/212F. POLYMER
FILM CAN BURN.
=======================================================
Control Measures
=======================================================
Respiratory Protection: WEAR SUITABLE RESPIRATOR (MSHA/NIOSH APPROVED OR
EQUIVALENT) WHERE EXPOSURE LIMITS ARE EXCEEDED.
Ventilation: MECHANICAL LOCAL EXHAUST AT POINT OF VAPOR OR MIST RELEASE.
Other Protective Equipment: ANSI APPROVED EMERGENCY EYE WASH AND DELUGE SHOWER
(FP N).
Work Hygienic Practices: REMOVE CONTAMINATED CLOTHING AS SOON AS POSSIBLE.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 212F,100C
M.P/F.P Text: 32.0F,0.0C
Vapor Pres: 17 @ 68F
Vapor Density: <1
Solubility in Water: DILUTABLE
Appearance and Odor: ORANGE LIQUID; LATEX EMULSION.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: DECOMPOSITION IS DEPENDENT ON TIME AND
TEMPERATURE. ONSET OF DECOMPOSITION IS 177C/350F.
Materials To Avoid: STRONG OXIDIZING MATERIALS.
Hazardous Decomposition Products: CARBON DIOXIDE, CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: EXTREME HEAT OR FREEZING CONDITIONS.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: AVIATION ORANGE VINYL ACRYLIC, PNT NP O5
Cage: 0ACJ7
Company Name: UNR-ROHN
Street: 6718 W. PLANK RD
PO Box: 2000
Zipcode: 61604
Label Required IND: Y
Date Of Label Review: 11/28/1995
Status Code: C
Label Date: 11/28/1995
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE:INHALATION:VAPORS OR MISTS CAN CAUSE HEADACHE,
NAUSEA, AND IRRITATION OF THE NOSE, THROAT AND LUNGS. EYE CONTACT:IRRITATING
TO EYES. CHRONIC:SKIN:IRRITATING TO SKIN UPON REPEATED OR PROLONGED CO NTACT.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CYLINDER OIL 680
Preparer's Name:R G FARMER
CAGE:15958
CAGE:15958
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENT REFINED RESIDUUM
CAS:64742-01-4
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE SUPP DATA
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/INHAL: NO SIGNIFICANT HEALTH
HAZARDS IDENTIFIED. SKIN: NONE EXPECTED FOR SINGLE SHORT-TERM
EXPOSURES. PROLONGED OR REPEATED CONTACT MAY PRODUCE SOME
IRRITATION. INGEST: EXPECTED TO BE RELATIVELY NON-TOXIC.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SKIN: PROLONGED OR REPEATED CONTACT MAY PRODUCE
SOME IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH PLENTY OF WATER. SKIN: WASH WITH SOAP AND
WATER. INHAL: IF ADVERSE EFFECTS OCCUR, REMOVE TO UNCONTAMINATED
AREA. INGEST: IF A LARGE AMOUNT IS SWALLOWED, INDUCE VOMITING. GET
MEDICAL A TTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:520F,271C (MIN)
Extinguishing Media:AGENTS APPRVD FOR CLASS B HAZ (E.G. DRY CHEMICAL,
CARBON DIOXIDE, HALOGENATED AGENTS, FOAM, STEAM) OR WATER FOG
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:TREAT AS AN OIL SPILL. CONTAIN AND REMOVE BY
MECHANICAL MEANS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL STORAGE REQUIREMENTS.
Other Precautions:AVOID STRONG OXIDIZERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Ventilation:ADEQUATE VENTILATION
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
LD50-LC50 MIXTURE: SKIN-LD50 FOR A SIMILAR PRODUCT:(DERMAL)>5.0
G/KG(RABBIT); INGEST-LD50 FOR A SIMILAR PRODUCT:(ORAL)>10.0
G/KG(RAT).
================== Physical/Chemical Properties ==================
Spec Gravity:0.91
Solubility in Water:NEGLIGIBLE, < 0.1%
Appearance and Odor:PALE COLORED, VISCOUS, OILY LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:INCOMPLETE BURNING CAN PRODUCE CARBON
MONOXIDE AND/OR CARBON DIOXIDE AND OTHER HARMFUL PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH APPLICABLE
FEDERAL, STATE, OR LOCAL REGULATIONS. ENCLOSED-CONTROLLED
INCINERATION IS RECOMMENDED UNLESS DIRECTED OTHERWISE BY APPLICABLE
ORDINANCES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TECTYL 894
CAGE:33150
CAGE:33150
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL SPIRITS
RTECS #:SE7550000
ACGIH TLV:500 PPM
Ingred Name:100 PALE OIL
ACGIH TLV:5 MG/CUM
===================== Hazards Identification =====================
Effects of Overexposure:EYES-SEVERE IRRITATION. SKIN-DEFATTING;
DERMATITIS. INHALATION-IRRITATION; DIZZINESS AND NAUSEA.
======================= First Aid Measures =======================
First Aid:SKIN-WASH WITH SOAP AND WATER. REMOVE CONTAMINATED
CLOTHING-WASH BEFORE REUSE. EYES-FLUSH WITH LARGE AMOUNTS OF
WATER.SWALLOWING-DO NOT INDUCE VOMITING-CALL PHYSICIAN. IF
BREATHING DIFFICULT,ADMINISTE R OXYGEN. APPLY ARTIFICIAL
RESPIRATION IF NEEDED.
===================== Fire Fighting Measures =====================
Flash Point:100F; 38C CC
Lower Limits:0.8
Extinguishing Media:DRY CHEMICAL, FOAM, CO2
Fire Fighting Procedures:SELF-CONTAINED WITH FACE PIECE-POSITIVE
PRESSURE MODE
Unusual Fire/Explosion Hazard:VAPORS HEAVIER THAN AIR AND MAY TRAVEL
ALONG GROUND. RESIDUE IN EMPTY DRUM CAN IGNITE.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL-ABSORB ON ABSORBENT MATERIAL AND
TRANSFER TO HOOD. LARGE-STOP SPILL AT SOURCE; DIKE AREA; PUMP
LIQUID TO SALVAGE TANK. REMAINING MATERIAL MAY BE ABSORBED ON SAND
OR CLAY AND SHOVELED INTO CONTAI NERS.
======================Handling and Storage ======================
Handling and Storage Precautions:ALL HAZARD PRECAUTIONS SHOULD BE
APPLIED TO EMPTIED CONTAINER SINCE RESIDUE REMAINS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELF-CONTAINED APPARATUS WITH FACEPIECE IF TLV
EXCEEDED
Ventilation:LOCAL AND MECHANICAL
Other Protective Equipment:IMPERVIOUS CLOTHING AND BOOTS SHOULD BE
WORN.
Supplemental Safety and Health
% MINERAL SPIRITS: 30-60
% 100 PALE OIL: 10-30
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:300F; 149C
Vapor Pres:2
Vapor Density:>1
Spec Gravity:0.87
Evaporation Rate & Reference:< ETHER
Solubility in Water:NA
Appearance and Odor:NA
Percent Volatiles by Volume:30
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:CO, CO*2; VARIOUS HYDROCARBONS AND
SULFUR COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:SMALL-VOLATILE PORTION TO EVAPORATE IN HOOD.
DESTROY REMAINING MATERIAL BY BURNING IN AN IRON PAN. LARGE-DESTROY
BY LIQUID INCINERATION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:7280 INDUSTRIAL ENAMELS
CAGE:08882
CAGE:08882
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS
*97-1*
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 30-55%
Other REC Limits:525 MG/CUM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: HARMFUL. MAY AFFECT THE
BRAIN & NERVOUS SYSTEM. CAUSES NOSE & THROAT IRRITATION. EYES/SKIN:
CAUSES IRRITATION WHICH CAN LEAD TO DERMATITIS. INGESTION: MAY
CAUSE GASTROINTESTINAL IRRITATION .
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DIZZINESS, HEADACHE, NAUSEA,
STAGGERING GAIT, CONFUSION, UNCONSCIOSNESS/COMA, VOMITING, DIARRHEA
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FORM AREA. RESTORE BREATHING. EYES: FLUSH
IMMEDIATELY W/LARGE AMOUNTS OF WATER FOR 15 MINS. SKIN: WASH
AFFECTED AREA W/SOAP & WATER. INGESTION: DON'T INDUCE VOMITING.
KEEP WARM, QUI ET. ASPIRATION INTO LUNGS CAN CAUSE CHEMICAL
PNEUMONITIS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:102-105F
Extinguishing Media:CO2, DRY CHEMICAL/FOAM
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT INCLUDING SCBA.
WATER SPRAY MAY BE INEFFECTIVE. WATER MAY BE USED TO COOL CLOSED
CONTAINERS. FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELETRICAL EQUIPMENT, SPARKS & OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE DUE TO EXTREME HEAT. (SUPP)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION, VENTILATE &
REMOVE W/INERT ABSORBENT & NONSPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE ABOVE 120F. CONTAINERS
SHOULD BE GROUNDED WHEN POURING. EMPTY CONTAINERS MAY BE HAZARDOUS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED CHEMICAL CARTRIDGE RESPIRATOR
TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY & ORGANIC VAPORS
DURING SPRAY APPLICATION.
Ventilation:PROVIDE GENERAL DILUTION/LOCAL EXHAUST VENTILATION IN
VOLUME & PATTERN TO KEEP TLV OF HAZARDOUS INGREDIENTS BELOW TLV.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
UNUSUAL FIRE CONT'D: DON'T APPLY TO HOT SURFACES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:307-389F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:50-65
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ELECTRICAL EQUIPMENT
Stability Condition to Avoid:HEAT, SPARKS & OPEN FLAME
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T INCINERATE CLOSED CONTAINERS. DISPOSE OF
IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:KBX33P506QAX
CAGE:09023
CAGE:09023
CAGE:14655
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR.AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UNC ONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BATTERY, STORAGE
Preparer's Name:WILLIAM O. WILDER, JR.
CAGE:09052
CAGE:09052
============= Composition/Information on Ingredients =============
Ingred Name:CADMIUM, CADMIUM HYDROXIDE
CAS:7440-43-9
RTECS #:EU9800000
Fraction by Wt: 14.63%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE 1910.1027
ACGIH TLV:0.01 MG/M3 DUST;9394
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:NICKEL, NICKEL HYDROXIDE
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 26.07%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9293
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 6.5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C, 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: POTASSIUM HYDROXIDE-SKIN BURNS.
NICKEL, NICKEL HYDROXIDE, CADMIUM, CADMIUM HYDROXIDE-POSSIBLE
CONTACT DERMATITIS. CHRONIC: NICKEL, NICKEL HYDROXIDE-SUSPECTED
CARCINOGENS. CADMIUM, CADMIUM HYDRO XIDE-RENAL FAILURE, RESPIRATORY
PROBLEMS.
Explanation of Carcinogenicity:CADMIUM, NICKEL ARE BOTH LISTED BY IARC
AND NTP AS ANIMAL POSITIVE CARCINOGENS.
Effects of Overexposure:POSSIBLE SKIN BURNS.
======================= First Aid Measures =======================
First Aid:WASH THOROUGHLY WITH LARGE VOLUMES OF WATER. INHALE: REMOVE
TO FRESH AIR, SEE PHYSICIAN. EYES: WASH WITH LARGE VOLUMES OF
WATER, SEE PHYSICIAN. SKIN: WASH WITH LARGE VOLUMES OF WATER.
INGEST: CONTACT A PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:IF INCINERATED, WEAR BREATHER UNITS.
Unusual Fire/Explosion Hazard:CADMIUM OXIDE FUMES/VAPORS/DUST.
================== Accidental Release Measures ==================
Spill Release Procedures:FOLLOW HAZARDOUS WASTE CLEAN-UP PROCEDURES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT BREAK OPEN BATTERY CASE.
Other Precautions:DO NOT INCINERATE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AIR BREATHER UNITS (ONLY IF MATERIALS ARE
INCINERATED).
Other Protective Equipment:RUBBER OR PLASTIC GARMENTS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:B1
================= Stability and Reactivity Data =================
NOT APPLICABLE.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:SUBLIMES AS CADMIUM OXIDE AT 2800F.
==================== Disposal Considerations ====================
Waste Disposal Methods:SEND TO A CERTIFIED HAZARDOUS WASTE DISPOSAL
SITE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:386 SEALANT, 386
CAGE:N0RDS
CAGE:N0RDS
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL, PETROLEUM DISTILLATES, SOLVENT REFINED (SEVERE),
HEAVY PARAFFINIC; (SEVERELY SOLVENT-REFINED OIL)
CAS:64741-88-4
RTECS #:PY8040501
Fraction by Wt: 75-85%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:STEARIC ACID, LITHIUM SALT; (LITHIUM STEARATE)
CAS:4485-12-5
RTECS #:WI4370000
Fraction by Wt: 13-17%
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:STEARIC ACID, CALCIUM SALT; (CALCIUM STEARATE)
CAS:1592-23-0
RTECS #:WI3000000
Fraction by Wt: 1-3%
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:SILICATE, MICA; (MICA) (MFR CAS # 12003-38-2)
CAS:12001-26-2
RTECS #:VV8760000
Fraction by Wt: 2-4%
OSHA PEL:3 MG/M3
ACGIH TLV:3 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: NONE EXPECTED. INGEST: PRODUCT
HAS LOW ORDER OF ACUTE ORAL TOXICITY. SKIN: PROLONGED/REPEATED SKIN
CONTACT MAY CAUSE IRRITATION. EYES: PRODUCT CONTACTING EYES MAY
CAUSE TEMPORARY IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH FOR AT LEAST 15 MINUTES WITH CLEAR WATER. CONTACT
PHYSICIAN. SKIN: WASH THOROUGHLY WITH SOAP AND WATER. INHAL: VAP
PRESS IS LOW. VAP INHAL IS NOT CONSIDERED A PROBLEM UNDER NORM
USAGE CNDT NS. REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE O*2/ARTF
RESP) . INGEST: DO NOT INDUCE VOMITING. CONTACT PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:495F,257C
Extinguishing Media:DRY CHEMICAL POWDER, CARBON DIOXIDE, CHEMICAL FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . TREAT AS BURNING OIL.
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER FREE MATERIAL. ADD SUITABLE ABSORBANT
TO SPILL AREA. CLEAN SPILL AREA W/DETERGENT SOLUTION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN SEALED CONTAINERS TO AVOID
CONTAMINATION WITH FOREIGN PARTICLES.
Other Precautions:STORE AWAY FROM HEAT AND OXIDIZING MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATORY PROTECTION NOT NEEDED UNDER NORMAL
USAGE CONDITIONS. USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:ADEQUATE VENTILATION I/A/W GOOD ENGINEERING PRACTICE IS
SUFFICIENT.
Other Protective Equipment:NONE NORMALLY NEEDED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Vapor Pres:NIL
Vapor Density:>10
Spec Gravity:0.89@75F
Evaporation Rate & Reference:NIL(ETHER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TAN, GREASE-LIKE MATERIAL IN STICK FORM. MILD
PETROLEUM HYDROCARBON ODOR.
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION MAY PRDCE CARBON
MONOXIDE, CARBON DIOXIDE, LITHIUM OXIDE, & ASPHXIANTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN A FURNANCE OR OTHERWISE DISPOSE OF
I/A/W ALL APPLICABLE FEDERAL, STATE AND LOCAL REQUIREMENTS AND
REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
NIIN: 01-374-0902
Product ID: IBM LASER PRINTER HIGH YIELD CARTRIDGE #1380200
Cage: NO504
=======================================================
Contractor Summary
=======================================================
Cage: NO504
Cage: 0SD37
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: CARTRIDGE,TONER
Unit of Issue: EA
UI Container Qty: 0
=======================================================
Ingredients
=======================================================
Cas: 25767-47-9
% Wt: 80-90
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Cas: 1333-86-4
RTECS #: FF5800000
% Wt: 5-15
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 3.5 MG/M3
ACGIH TLV: 3.5 MG/M3
------------------------------
% Wt: <3.0
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
-----------------------------
% Wt: <3.0
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
-----------------------------
% Wt: <3.0
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 15 MG/M3
ACGIH TLV: 10 MG/M3
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: SKIN: RASH. EYE: IRRITATION.
Signs And Symptions Of Overexposure: TONER ON SKIN OR MUCOUS MEMBRANE
(MOUTH/NOSE).
First Aid: INHAL: GET FRESH AIR. SKIN: WASH W/SOAP & WATER. EYE: FLUSH
W/WATER FOR 15 MINUTES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: IF DUST CLOUD IS POSSIBLE, REMOVE ALL IGNIT SOURCES.
MINIMIZE DUST GENERATION DURING CLEANUP. SWEEP UP SPILL W/NONMETALLIC
BROOM/DUSTPAN. CONTAIN FOR DISPOSAL.
Waste Disposal Methods: IN ACCORDANCE W/FEDERAL, STATE & LOCAL REGULATIONS.
Handling And Storage Precautions: AVOID EXCESS HAT DURING STORAGE. KEEP AWAY
FROM CHILDREN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NA
Autoignition Temp Text: NA
Lower Limits: NA
Upper Limits: NA
Extinguishing Media: WATER, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: FIRE MAY PRODUCE HAZARDOUS DECOMPOSITION PRODUCTS
SUCH AS OXIDES OF CARBON & UNIDENTIFIED ORGANICS.
Unusual Fire/Explosion Hazard: TONER DUST MAY DIVIDE MATERIAL IN HIGH
CONCENTRATIONS & CAN FORM EXPLOSIVE MIXTURES IN AIR. IF IGNITED, COULD
RESULT IN DUST EXPLOSION. CARBON DIOXIDE, CARBON
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE
Ventilation: MECHANICAL ROM VENT.
Other Protective Equipment: NONE
Supplemental Safety and Health: * MONOXIDE, SILICON OXIDE LOW MOLECULAR WEIGHT
ORGANIC.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: NA
Vapor Density: NA
PH: NA
Evaporation Rate & Reference: NA
Solubility in Water: INSOLUBLE
Appearance and Odor: BLACK POWDER, W/FAINT ODOR.
Percent Volatiles by Volume: NA
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: OXIDIZERS.
Hazardous Decomposition Products: OXIDES OF CARBON & SILICON OXIDES, IDENTIFIED
ORGANICS.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 130337
Product ID: IBM LASER PRINTER HIGH YIELD CARTRIDGE #1380200
Review Date: 12/08/1997
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: EA
Container QTY: 0
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: IBM LASER PRINTER HIGH YIELD CARTRIDGE #1380200
Cage: NO504
Assigned IND: Y
Company Name: LEXMARK
Street: 740 NEW CIRCLE ROAD NORTHWEST
Zipcode: 40511
Label Required IND: Y
Date Of Label Review: 10/12/1999
Status Code: A
Origination Code: G
Hazard And Precautions: SKIN: RASH. EYE: IRRITATION.
=======================================================
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:ATA 101AL CONVENTIONAL POWDER ATOMIZED ALUMINUM POWDER
CAGE:9X812
CAGE:9X812
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM
CAS:7429-90-5
RTECS #:BD0330000
< Wt:100.
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:INHALATION: ALUMINUM DUSTS MAY HAVE
LITTLE ADVERSE EFFECT ON LUNGS & DON'T PRODUCE SIGNIFICANT ORGANIC
DISEASE/TOXIC EFFECTS WHEN EXPOSURES ARE KEPT UNDER CONTROL. SKIN:
IRRITATION ON REPEATED CONTACT . EYES: ABRASION.
Explanation of Carcinogenicity:M[
Effects of Overexposure:IRRITATION, ABRASION
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SKIN: WASH W/SOAP & WATER.
EYES: FLUSH W/WATER FOR 15 MINS. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Lower Limits:2
Upper Limits:12
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:DON'T USE WATER. USING SAND, GENTLY COVER THE
BURNING POWDER & FORM A RING AROUND IT W/EXTINGUISHING AGENTS
RECOMMENDED. DON'T MIX THE AGENT W/THE BURNING POWDER & DON'T
DISTURB THE POWDER UNTIL IT CO OLS GENTLY OVER THE BURNING POWDER.
AT NO TIME ALLOW DUST CLOUDS TO BE FORMED.
Unusual Fire/Explosion Hazard:DON'T USE CLASS A, B, C EXTINGUISHING
AGENTS/HALOGENATED AGENTS. MAY REACT VIOLENTLY FORMING HYDROGEN GAS
& ALUMINUM OXIDE. ALUMINUM PARTICLES WILL BURN AT A VERY HIGH
TEMP/BE EXPLOSIVE IF LOOSENED & DISPERSED IN AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. KEEP PEOPLE AWAY.
AVOID EXPOSURE TO SPARKS, FIRE/HOT METAL SURFACES. USING
NON-SPARKING TOOLS, TRANSFER MATERIAL TO LEAKPROOF CONTAINER FOR
HAZARDOUS DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY AREA
W/VENTILATION SUITABLE FOR STORING MATERIALS.
Other Precautions:USE NON-SPARKING HANDLING EQUIPMENT. COVER & RESEAL
PARTIALLY EMPTY CONTAINERS. KEEP COMPLETELY DRY, STORAGE AREAS MUST
BE OF FIRE RESISTANT CONSTRUCTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE SUPPLIED AIR RESPIRATOR PROTECTION IN
CONFINED/ENCLOSED SPACES IF NEEDED.
Ventilation:LOCAL EXHAUST, EXPLOSION PROOF. MINIMUM FACE VELOCITY OF 60
F. P. M. NO SMOKING/OPEN LIGHTS.
Other Protective Equipment:CHEMICAL RESISTANT APRON
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE. WASH HANDS BEFORE EATING/SMOKING. SMOKE IN DESIGNATED
AREAS ONLY.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Solubility in Water:NONE
Appearance and Odor:SILVERY GRAY POWDER
Percent Volatiles by Volume:0.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, ACIDS/ALKALIS, CHLORINATED HYDROCARBONS, STRONG OXIDIZERS
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAMES
Hazardous Decomposition Products:CO, COMBUSTIBLE HYDROGEN GAS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN APPROVED HAZARDOUS WASTE LANDFILL
IN ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:URALITE 3130-3132 PART A
Kit Part:Y
Preparer's Name:FRANK LEE
CAGE:0RNW1
CAGE:0RNW1
CAGE:01490
============= Composition/Information on Ingredients =============
Ingred Name:DIISOCYANATE POLYMER; (DICYCLOHEXYLMETHANE-4,4'
DIISOCYANATE [H12MDI]) LD50 (ORAL RAT): > 10000 MG/KG
CAS:5134-30-1
Fraction by Wt: 10-20%
OSHA PEL:0.010 PPM (MFR)
ACGIH TLV:0.005 PPM (MFR)
Ingred Name:POLYMER POLYOL POLYMER WITH METHYLENE BIS(4-CYCLOHEXY)
ISOCYANATE(POLYURETHANE PREPOLYMER
CAS:9042-82-4
Fraction by Wt: 80-90%
Ingred Name:VOLATILE ORGANIC CONTENT: 24 G/L
RTECS #:9999999VO
Ingred Name:SUP DAT: EYES W/SYMPS SUCH AS TEARS & REDNESS & SWELL OF
EYES. INGEST CAN CAUSE IRRIT OF MOUTH, STOM TISS & (ING 5)
Ingred Name:ING 4: DIGEST TRACT. SYMPS INCL SORE THROAT, ABDOM PAIN,
NAUS, VOMIT & DIARR.
Ingred Name:FIRST AID PROC: NEVER GIVE ANYTHING BY MOUTH TO UNCON PERS.
CONSULT MD. NOTE TO MD: EYES-STAIN FOR EVIDENCE OF (ING 7)
Ingred Name:ING 6: CORNEAL INJURY. IF CORNEA IS BURNED, INSTILL
ANTIBIOTIC/STEROID PREPARATION. WORKPLACE VAPS COULD PRDCE (ING 8)
Ingred Name:ING 7: REVERSIBLE CORNEAL EPITHELIAL EDEMA IMPAIRING
VISION. SKIN-H12MDI IS A KNOWN SKIN SENSITIZER. TREAT (ING 9)
Ingred Name:ING 8: SYMPTOMATICALLY FOR CONT DERM. INGEST-TREAT
SYMPTOMATICALLY; NO SPECIFIC ANTIDOTE. DUE TO IRRIT NATURE (ING 10)
Ingred Name:ING 9: OF H12MDI, INDUCED VOMIT NOT REC. RESP-TREATMENT IS
ESSENTIALLY SYMPTOMATIC. PERS HAVING SKIN/PULMONARY (ING 11)
Ingred Name:ING 10: SENSIT TO THIS MATL SHOULD BE REMOVED FROM ALL
EXPOS TO ANY ISOCYANATE. MEDICAL SUPERVISION OF ALL (ING 12)
Ingred Name:ING 11: EMPLOYEES WHO COME IN CONT W/ANY ISOCYANATE IS REC.
THIS SUPERVISION SHOULD INCL PRE-EMPLOYMENT & (ING 13)
Ingred Name:ING 12: PERIODIC MED EXAMINATIONS W/PULM FUNCTION TESTS.
PERS W/ASTHMATIC-TYPE CNDTNS, OTHER CHRONIC RESP (ING 14)
Ingred Name:ING 13: CNDTNS, RECURRENT SKIN ECZEMA/SKIN SENSIT SHOULD
NEVER WORK W/ISOCYANATES. ONCE A PERS IS DIAGNOSED AS (ING 15)
Ingred Name:ING 14: SENSITIZED TO AN ISOCYANATE, NO FURTHER EXPOSURE
CAN BE PERMITTED.
Ingred Name:SPILL PROC: 5-8% CONCENTRATED AMMONIA AND 1-2% DETERGENT
BEFORE DISPOSAL. KEEP CONTAINER OPEN FOR AT LEAST (ING 17)
Ingred Name:ING 16: 24 HOURS SO THAT EVOLVED CARBON DIOXIDE CAN ESCAPE.
Ingred Name:RESP PROT: DETECTABLE ODOR OR IRRITATION. FOR THIS REASON,
NIOSH/MSHA APPROVED AIR-PURIFYING RESPS ARE NOT RECOMMENDED.
Ingred Name:VENT: USED TO MAINTAIN H12MDI LEVELS BELOW THE PEL WHENEVER
THIS PRODUCT IS PROCESSED OR HEATED. STANDARD (ING 20)
Ingred Name:ING 19: REFERENCE SOURCES REGARDING INDUSTRIAL VENTILATION
(E.G. ACGIH INDUSTRIAL VENTILATION) SHOULD BE CONSULTED.
Ingred Name:OTHER PROT EQUIP: BOOTS, APRON/FULL-BODY SUIT WILL DEPEND
ON THE OPERATION. COVER AS MUCH OF THE EXPOSED SKIN (ING 22)
Ingred Name:ING 21: AREA AS POSSIBLE WITH APPROPRIATE CLOTHING.
Ingred Name:HYGIENE PRACT: AMOUNTS OF THIS MATERIAL GET ON WORK
CLOTHES, THE EMPLOYEE SHOULD SHOWER IMMEDIATELY AND THE (ING 24)
Ingred Name:ING 23: CLOTHING SHOULD BE LAUNDERED BEFORE IT IS WORN
AGAIN.
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: H12MDI VAPS CAN IRRITATE MUC
MEMB, CAUSING RUNNY NOSE, SORE THROAT, COUGHING, CHEST DISCOMFORT &
SHORTNESS OF BRTH. EXPOS TO VAPS > PEL MAY RSLT IN BRONCH, BRONCH
SPASMS & PULM EDEMA (FLUID IN LUNGS). CHEM/HYPERSENSITIVE PNEUMIT
W/FLU-LIKE SYMPS (FEVER, CHILLS) CAN OCCUR. THESE SYMPS MAY BE
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: DELAYED & OCCUR SEVERAL HRS AFTER
EXPOS. CERTAIN PEOPLE MAY DEVELOP SENSIT TO H12MDI & WILL EXHIBIT
ASTHMA-LIKE ATTACKS AT ANY ISOCYANATES CONC. CROSS-SENSIT TO
DIFFERENT ISOCYANATES MAY ALS O OCCUR. THIS SENSIT MAY BE
TEMPORARY/PERM. CHRONIC OVEREXP TO ISOCYANATES MAY ALSO CAUSE LUNG
DMG, INCL PERM (SUP DAT)
Medical Cond Aggravated by Exposure:PREEXISTING EYE, SKIN AND
RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS
PRODUCT. THESE MEDICAL CONDITIONS INCLUDE ASTHMA, BRONCHITIS,
EMPHYSEMA, SKIN ALLERGIES AND ECZEMA.
======================= First Aid Measures =======================
First Aid:EYES: IMMED FLUSH W/PLENTY OF (PREF LUKEWARM) WATER FOR AT
LEAST 15 MIN, KEEPING EYELIDS OPEN ALL THE TIME. SEEK IMMED MED
ATTN. SKIN: IMMED WASH W/SOAP & PLENTY OF WATER. WASH CONTAM CLTHG
BEFORE REU SE & DESTROY CONTAM SHOES. INHAL: REMOVE TO FRESH AIR.
IF NOT BRTHG, GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE OXYGEN. GET
MED ATTN. INGEST: DO NOT INDUCE VOMIT. GIVE 1-2 GLASSES OF
MILK/WATER. (ING 6)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:430F,221C
Extinguishing Media:USE WATER SPRAY, DRY CHEMICAL OR CARBON DIOXIDE TO
EXTINGUISH FIRES. USE WATER TO KEEP CONTAINERS COOL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN W/SUITABLE DIKING MATL. IN ADDN TO
PROT EQUIP, WEAR IMPERMEABLE BOOTS. VENT AREA THORO. KEEP ALL UNNEC
PEOPLE AWAY. SPILLED MATL SHOULD BE ABSORBED IN SAWDUST, SAND/OTHER
ABSORB. PLACE INTO OP EN-TOP CONTR. NEUT W/SOLN OF 90-95%
WATER,(ING 16)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH EYES, SKIN AND
CLOTHING. AVOID BREATHING VAPORS. KEEP THE CONTAINERS CLOSED. KEEP
MATERIAL AWAY FROM HEAT, SPARKS & OPEN FLAMES.
Other Precautions:STORE IN A COOL, WELL-VENTILATED AREA IN TIGHTLY
CLOSED CONTAINERS. AVOID MOISTURE CONTAMINATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD POS PRESS, SUPP-AIR RESP/SCBA
IS REQUIRED WHENEVER AIRBORNE H12MDI CONC IS UNKNOWN/EXCEEDS 0.005
PPM. H12MDI HAS POOR WARNING PROPERTIES. THIS MEANS THAT PEL MAY
ALREADY BE EXCEEDED BEFORE THERE WOULD BE ANY (ING 18)
Ventilation:USE EXHST VENT TO KEEP AIRBORNE LEVELS < OSHA-REC EXP LIM.
DO NOT USE IN POORLY VENT AREA. LOC EXHST SHOULD BE (ING 19)
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
21)
Work Hygienic Practices:BEFORE EATING, DRINKING, SMKNG/USING TOILET
FACILITIES, WASH FACE & HANDS THORO W/SOAP & WATER. IF SIGNIFICANT
(ING 23)
Supplemental Safety and Health
EFTS OF OVEREXP: DECRD LUNG FUNCTION. SKIN CONT MAY CAUSE REDDENING,
SWELL, RASH, SCALING/BLISTERING. PRLNG SKIN CONT CAUSES IRRIT THAT
MAY RSLT IN CHEM SENSIT. H12MDI IS A POTENT SKIN SENSIT. PEOPLE
DERMALLY SENSITD TO H12MDI MAY ALSO EXHIBIT RESP ALLERGIC RESPONSES
TO AIRBORNE H12MDI. THIS PROD WILL IRRITATE (ING 4)
================== Physical/Chemical Properties ==================
Vapor Pres:0.001@25C
Solubility in Water:N/A (REACTS)
Appearance and Odor:CLEAR TO SLIGHTLY YELLOW LIQUID, WITH A FAINT,
SWEET ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH WATER, ALCOHOLS, STRONG BASES, METAL COMPOUNDS OR
SURFACE ACTIVE MATERIALS.
Stability Condition to Avoid:MOISTURE CONTAMINATION MAY RESULT IN
CARBON DIOXIDE GAS PRESSURE.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN, TRACES OF HCN, AND H12MDI VAPORS/MIST.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED INCINERATION OR BURIED LANDFILL
DISPOSAL SHOULD BE IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGULATIONS.
======================================================================
| 1 | gloves_mandatory |
=======================================================
NIIN: 01-380-4053
Product ID: GRISOLVE PEG-2 (CONCENTRATE)
Cage: 27843
=======================================================
Item Description Information
=======================================================
Item Manager: S9G
Item Name: CLEANING COMPOUND,SOLVENT
Unit of Issue: DR
Quantitative Expression: 00000000055GL
UI Container Qty: 1
Type of Container: DRUM
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: NOT AVAILABLE. (ELSEWHERE IN MSDS MANUFACTURER STATES: CAN
CAUSE EYE DAMAGE AND SKIN IRRITATION. HARMFUL IF SWALLOWED. INHALATION MAY
CAUSE NAUSEA. )
Explanation Of Carcinogenicity: PRODUCT IS NOT LISTED AS A CARCINOGEN BY NTP,
IARC OR REGULATED AS SUCH BY OSHA.
Signs And Symptions Of Overexposure: NONE DESCRIBED IN MSDS. :EYE:
IRRITATION, REDNESS, PAIN. SKIN: IRRITATION. INGESTION: NAUSEA, VOMITING,
STOMACHACHE. . INHALATION: IRRITATION OF RESPIRATORY TRACT, NAUSEA.
Medical Cond Aggravated By Exposure: CAN CAUSE EYE DAMAGE AND SKIN IRRITATION.
HARMFUL IF SWALLOWED. INHALATION MAY CAUSE NAUSEA. (PER MSDS)
First Aid: INHALED-REMOVE TO FRESH AIR. EYES: REMOVE CONTACT LENSES. FLUSH WITH
WATER FOR 15-20 MINUTES. SKIN-REMOVE CONTAMINATED CLOTHES. WASH WITH PLENTY
OF SOAP & WATER. INGESTED-DRINK WATER TO DILUTE SUBSTAN CE.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SMALL SPILLS SHOULD BE ABSORBED BY DIRT, SAND OR
SUITABLE ABSORBENT. LARGE SPILLS MAY BE DIKED WITH EARTH OR PUMPED TO CLOSED
CONTAINER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE AT A GOVERNMENT APPROVED LANDFILL, INCINERATION
OR RECOVERY FACILITY. OBSERVE LOCAL, STATE & FEDERAL REGULATIONS.
Handling And Storage Precautions: DO NOT STORE NEAR STRONG OXIDIZING AGENTS.
Other Precautions: NOT AVAILABLE.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point: =61.1C, 142.F
Extinguishing Media: DRY CHEMICAL, FOAM, CARBON DIOXIDE (CO2), WATER BY SPRAY
ONLY.
Fire Fighting Procedures: NONE SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard: COMBUSTIBLE LIQUID. AVOID, HEAT, SPARKS &
OPEN FLAMES. AS IN THE CASE OF MOST OIL-BASED PRODUCTS CONTAMINATED RAGS AND
ABSORBENTS SOAKED WITH THIS PRODUCT MAY IGNITE SPONTANEOUSLY. ALWAYS PLACE
USEDMATERIALS IN AIR TIGHT METAL CANS CONTAINING SOAPY WATER. DO NOT
DISOPOSE OF MATERIALS IN OPEN TRASH BINS OF DUMPSTERS.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE NORMALLY REQUIRED.
Ventilation: NORMALLY NOT NEEDED ( USE MECHANICAL/ GENERAL IN CONFINED AREAS )
Other Protective Equipment: NONE NORMALLY REQUIRED.
Work Hygienic Practices: ALWAYS USE GOOD HYGIENE. WASH THOROUGHLY BEFORE
EATING/DRINKING/SMOKING & AT END OF WORKDAY.
Supplemental Safety and Health: ITEM IS NOT A PRIMARY IRRITANT.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: V5
Boiling Point: =187.C, 368.6F
Vapor Density: CA.4.6
Spec Gravity: 0.863 @ 15.5C
Solubility in Water: NEGLIGIBLE
Appearance and Odor: PALE YELLOW/ PINE ODOR
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: MATERIAL IS STABLE.
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: CARBON DIOXIDE, CARBON MONOXIDE, FUMES.
=======================================================
Toxicological Information
=======================================================
Toxicological Information: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Ecological Information
=======================================================
Ecological: NONE SPECIFIED BY MANUFACTURER.
=======================================================
=======================================================
Transport Information: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: NONE SPECIFIED BY MANUFACTURER.
Federal Regulatory Information: NONE SPECIFIED BY MANUFACTURER.
State Regulatory Information: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Other Information
=======================================================
Other Information: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Transportation Information
=======================================================
Trans ID NO: 149238
Product ID: GRISOLVE PEG-2 (CONCENTRATE)
Review Date: 10/15/1999
Net Unit Weight: 395 LB/DR
Multiple KIT Number: 0
Unit Of Issue: DR
Container QTY: 1
Type Of Container: DRUM
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: GRISOLVE PEG-2 (CONCENTRATE)
Cage: 27843
Company Name: GRIGNARD CO INC
Street: 900 PORT READING AVE
Zipcode: 07064-1044
Label Required IND: Y
Date Of Label Review: 10/15/1999
Status Code: A
Year Procured: 1999
Origination Code: F
Signal Word: CAUTION
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: WARNING! BIODEGRADABLE BEG-2 SOAKED RAGS MAY
SPONTANEOUSLY COMBUST IN WASTE CONTAINERS. WET PEG-2 RAGS WITH WATER TO
PREVENT THE RISK OF SPONTANEOUS COMBUSTION. HEALTH HAZARDS NOT AVAILABLE.
(ELSEWHER E IN MSDS MANUFACTURER STATES: CAN CAUSE EYE DAMAGE AND SKIN
IRRITATION. HARMFUL IF SWALLOWED. INHALATION MAY CAUSE NAUSEA. ) FIRST
AID:-NHALED-REMOVE TO FRESH AIR. EYES: REMOVE CONTACT LENSES. FLUSH WITH
WATER FOR 15-20 MINUTES. SKIN-REMOVE CONTAMINATED CLOTHES. WASH WITH PLENTY
OF SOAP & WATER. INGESTED-DRINK WATER TO DILUTE SUBSTANCE. SEEK MEDICAL
HELP.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:VIRGO/A
CAGE:60217
CAGE:60217
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 45%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:POTASSIUM ALUMINUM SILICATE (FELDSPAR)
CAS:68476-25-5
Fraction by Wt: 16%
Other REC Limits:NONE SPECIFIED
Ingred Name:CALCIUM CARBONATE
CAS:471-34-1
RTECS #:FF9335000
Fraction by Wt: 4%
Other REC Limits:NONE SPECIFIED
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: 13%
Other REC Limits:NONE SPECIFIED
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 9%
Other REC Limits:NONE SPECIFIED
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:POTASSIUM SILICATE
CAS:1312-76-1
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:FUMES AND GASES CAN BE DANGEROUS TO
YOUR HEALTH. ARC RAYS CAN INJURE EYES AND BURN SKIN. ELECTRIC SHOCK
CAN KILL. NOISE CAN DAMAGE HEARING.
Effects of Overexposure:ACUTE:METALLIC TASTE,NAUSEA,TIGHTNESS OF
CHEST,FEVER,DIZZINESS,DRYNESS,IRRITATION OF EYES,NOSE AND THROAT.
CHRONIC:EXCESSIVE LEVELS MAY CAUSE BRONQUIAL ASTHMA,LUNG FIBROSIS
AND PNEUMOCONIOSIS.
Medical Cond Aggravated by Exposure:AGGRAVATION OF EXISTING RESPIRATORY
OR ALLERGIC CONDITIONS.HIGHER LEVEL OF LUNG RELATED PROBLEMS AMONG
SMOKERS.
======================= First Aid Measures =======================
First Aid:REMOVE FROM EXPOSURE AND OBTAIN PROMPT MEDICAL ATTENTION. IF
NOT BREATHING,GIVE CPR/OXYGEN. EMPLOY FIRST AID TECHNIQUES
RECOMMENDED BY AMERICAN RED CROSS.
===================== Fire Fighting Measures =====================
Extinguishing Media:NON-FLAMMABLE. USE MEDIA APPROPIATE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY. CONTAIN RUNOFF.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS. WELDING ARC CAN IGNITE
COMBUSTIBLES.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP ANY GRINDING DUST OR WASTE RESIDUE
AND PLACE IN APPROPIATE DISPOSAL CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN DRY AREA. ELECTRODES EXPOSED
TO MOISTURE MAY EXPLODE VIOLENTLY IF USED. DRY MOIST RODS BY BAKING
AT 300F FOR TEN HOURS.
Other Precautions:TRAIN WELDER TO KEEP HIS HEAD OUT OF THE
FUMES.MONITOR AIR TO ENSURE ACCEPTABLE EXPOSURES.AVOID ELECTRICAL
SHOCK BY MAINTAINING DRY WORK AREA. WELDING ARC CAN IGNITE
COMBUSTIBLES AND FLAMMABLES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FUME RESPIRATOR OR AIR SUPPLIED RESPIRATOR IN
CONFINED SPACES OR WHERE VENTILATION DOES NOT KEEP EXPOSURE BELOW
TLV.
Ventilation:LOCAL EXHAUST TO KEEP BELOW TLV.
Other Protective Equipment:SUBSTANTIAL DARK CLOTH,ARM
PROTECTOR,APRON,HAT AND SHOULDER PROTECTION. AIR SAMPLING TO
DETERMINE CORRECTIVE MEASURES.
Work Hygienic Practices:WASH HANDS THOROUGHLY BEFORE EATING,SMOKING OR
USING SANITARY FACILITIES.
Supplemental Safety and Health
NONE.
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:SOLID ROD,COATED WITH FLUX.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:FUMES OF METALS AND METAL OXIDES FROM
ELECTRODE AND BASE METAL, CARBON MONOXIDE, CARBON DIOXIDE, OZONE,
NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT WITH YOUR LOCAL ENVIRONMENTAL
OFFICER.DISPOSE OF FUMES,FLUX OR WELD GRINDING RESIDUE FROM THE
WORK AREA OR FROM FILTERS IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BATTERY ALKALINE ELECTROLYTE,POTASSIUM HYDROXIDE SOLUTION
CAGE:09052
CAGE:09052
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM HYDROXIDE (CERCLA)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: MAJOR
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:LITHIUM HYDROXIDE(CONTAMINANT)
CAS:1310-65-2
RTECS #:OJ6307070
Fraction by Wt: <3%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS 273MG/KG (KOH)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:**CORROSIVE** EYES:MAY CAUSE VERY
RAPID,SEVERE DAMAGE,POSSIBLY BLINDNESS.SKIN:MAY CAUSE
BURNS.INGEST:HARMFUL IF SWALLOWED.INHAL:MAY CAUSE RESPIRATORY
IRRITATION.
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of Overexposure:TISSUE BURNS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH WATER.GET MEDICAL
ATTENTION IF NEEDED.EYES:FLUSH WITH WATER FOR 15 MINUTES.GET
IMMEDIATE MEDICAL ATTENTION.INHAL:REMOVE TO FRESH AIR.GIVE OXYGEN
OR ARTIFICI AL RESPIRATION IF NEEDED.GET IMMEDIATE MEDICAL
ATTENTION.INGEST:DO NOT INDUCE VOMITING.GET PROMPT QUALIFIED
MEDICAL ATTENTION.IF CONSCIOUS,GIVE MILK.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY,DRY CHEMICAL,CARBON DIOXIDE,FOAM.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:THIS ITEM CAN RELEASE HYDROGEN GAS WHEN
IN CONTACT WITH AL,SN,ZN OR ITS ALLOYS.
================== Accidental Release Measures ==================
Spill Release Procedures:NEUTRALIZE WITH DILUTE ACETIC ACID.SOAK UP
WITH NON-COMBUSTIBLE INERT ADSORBANT(EG.CLAY);PLACE COLLECTED
MATERIAL IN AN APPROPRIATE CONTAINER FOR DISPOSAL.NEUTRALIZE
RESIDUE WITH SODIUM BICARBONATE.DI SPOSE OF RINSEATE PROPERLY.
Neutralizing Agent:DILUTE ACETIC ACID FOLLOWED BY SODIUM BICARBONATE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY,WELL-VENTILATED
PLACE.KEEP CONTAINER CLOSED WHEN NOT IN USE.KEEP AWAY FROM
HEAT,SPARKS,FLAMES AND INCOMPATIBLE MATERIALS.
Other Precautions:**DO NOT ADD WATER TO CAUSTIC** AVOID SKIN AND EYE
CONTACT.DO NOT INHALE VAPORS/MISTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE ENVIRONMENTAL CONTROLS ARE LACKING OR IN
ENCLOSED SPACES USE A NIOSH/MSHA APPROVED RESPIRATOR FOR ALKALINE
VAPORS.
Other Protective Equipment:PROTECTIVE CLOTHING,AS NEEDED.PROVIDE A
LOCAL EYE WASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS.SEPERATE WORK CLOTHES FROM STREET
CLOTHES.LAUNDER WORK CLOTHES BEFORE REUSE.KEEP FOOD OUT OF THE WORK
AREA.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:B1
Boiling Pt:=121.1C, 250.F
Vapor Pres:14
Spec Gravity:1.18-1.25
pH:BASIC
Solubility in Water:COMPLETE
Appearance and Odor:NOT REPORTED.LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AL,SN,ZN OR ITS ALLOYS,ORGANIC CHMICALS(THIS MATERIAL WILL REACT
W/TRICHLOROETHYLENE TO FOR SPONT COMB DICHLOROETHYLENE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:HYDROGEN GAS.
==================== Disposal Considerations ====================
Waste Disposal Methods:USE GENERAL DILUTION VENTILATION.
| 1 | gloves_mandatory |
=======================================================
Product ID: Y-470, EPO-11 BP EPOXY SAFETY YELLOW
Cage: 0BDY9
=======================================================
Contractor Summary
=======================================================
Cage: 0BDY9
=======================================================
Ingredients
=======================================================
SHOULD NOT BE REMOVED BY BURNING.
-----------------------------
-----------------------------
-----------------------------
USE NON-SPARKING TOOLS & EXPLO PROOF EQUIP.
-----------------------------
SURFACES. USE ONLY W/ADEQ VENT. HANDLE
-----------------------------
CNTNRS RETAIN RESIDUE (LIQ &/OR VAP) & CAN
-----------------------------
GRIND/EXPOSE SUCH CNTNRS TO HEAT, FLAME
-----------------------------
INJURY OR DEATH. DO NOT ATTEMPT TO CLEAN SINCE (ING 11
-----------------------------
DRAINED, PROPERLY BUNGED AND PROMPTLY
-----------------------------
DISPOSED IN AN ENVIRONMENTALLY SAFE MANNER
-----------------------------
Z49.1 AND OTHER GOVERNMENTAL & INDUST
-----------------------------
CONTAMPLATED OPERATIONS.
-----------------------------
TYPE RESP OR HOODS. WEAR APPROP PROPERLY
-----------------------------
UNLESS AIR MONITORING DEMONSTRATES VAPOR/MIST
-----------------------------
FOR RESPIRATOR USE.
-----------------------------
TO MAINTAIN EXPOSURE LEVEL <0.1 MG/M3.
-----------------------------
Cas: 108-10-1
RTECS #: SA9275000
20C. FL PT: 97F, 36C
% Wt: 6-16
OSHA PEL: 50 PPM;75 STEL
ACGIH TLV: 50 PPM;75 STEL
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 2807-30-9
RTECS #: KM2800000
3807-30-9)
% Wt: 3-13
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
% Wt: 36-46
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Cas: 1344-37-2
Other REC Limits: 0.01 MG/M3 (CR)
OSHA PEL: 0.1 PPM (CRO*3)
ACGIH TLV: 0.05 MG/M3 (PB)
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHAL:ANESTHETIC. IRRIT OF THE RESP TRACT OR ACUTE NERVOUS
SYSTEM DEPRESSION CHARACTERIZED BY HEADACHE, DIZZINESS, STAGGERING GAIT,
CONFUSION, UNCONSCIOUSNESS OR COMA. SKIN OR EYE CONTACT: PRIMARY IRR ITANT.
REPORTS HAVE ASSOC RPTD & PRLNGDOCCUP OVEREXP TO SOLVENTS W/PERMANENT
BRAIN & NERV SYS DMG. (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ: INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING AND INHALING THE CONTENTS MAY BE HARMFUL OR FATAL.
LEAD & LEAD CMPNDS APPEAR ON NAVY LISTING OF OCCUP CHEM REPROD HAZS. SEEK
CONSULTATION FRO M APPROP HLTH PROFESSIONALS CONCERNING LATEST HAZ LIST INFO
AND SAFE HANDLING & EXPOSURE INFORMATION (FP N).
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL: RESTORE BRTHG. KEEP WARM & QUIET. NOTIFY MD. EYE: FLUSH
IMMED W/COPIOUS QUANTITIES OF RUNNING WATER FOR AT LEAST 15 MIN. TAKE TO MD
FOR DEFINITIVE MED TREATMENT. SKIN: WASH AFFECTED AREAS WITHWATER. REMOVE
CONTAMINATED CLOTHING. CONSULT MD. INGEST: CALL MD OR POISON CONTROL CENTER
IMMED. DRINK 1 OR 2 GLASSES OF WATER TO DILUTE. TREAT SYMPTOMATICALLY. DO NOT
INDUCE VOMIT.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL IGNIT SOURCES. MOP UP SPILLS OR ADD
ABSORBENT. USE NON-SPARKING TOOLS. USE ADEQ VENT. MOVE LEAKING CNTNRS TO OUT
OF DOORS OBSERVING PRECAUTIONS WITH REFERENCE TO FIRE, SPARK & FLAME HAZ.
RU N OFF TO WATERWAY CREATES FIRE HAZS;
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: RECLAIM MATERIAL INCINERATE, OR USE SANITARY LANDFILL
METHOD OF DISPOSAL IN ACCORDANCE WITH STATE, LOCAL AND FEDERAL REGULATIONS.
DO NOT INCINERATE CLOSED CONTAINERS. SEAL EMPTY DRUMS TIGHTLY.
Handling And Storage Precautions: STORE IN WELL VENT WAREHOUSE. KEEP OUT OF
DIRECT SUNLIGHT OR OTHER HEAT SOURCE. KEEP CONTAINERS CLOSED. NO SMOKING. DO
NOT TAKE INTERNALLY.
Other Precautions: HARMFUL/FATAL IF SWALLOWED. CNTNRS SHOULD BE GROUNDED WHEN
POURING. AVOID FREE FALL OF LIQ IN EXCESS OF A FEW INCHES. CLOSE CNTNR AFTER
EACH USE. DO NOT TRANSFER CONTENTS TO BOTTLES OR OTHER UNLABELLE D CNTNRS.
AVOID PRLNGD CNTCT
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: INGRED 1
Lower Limits: INGRED 2
Extinguishing Media: FOAM, "ALCOHOL FOAM", CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures: WATER MAY BE INEFTIVE; HOWEVER, USE WATER SPRAY TO
COOL FIRE-EXPOSED CLOSED CNTNRS TO PVNT EXPLOSION. USE NIOSH/MSHA APPROVED
SCBA & FULL PROT EQUIP (FP N).
Unusual Fire/Explosion Hazard: TOX GASES ARE EVOLVED WHEN BURNING. KEEP CNTNRS
TIGHTLY CLSD. ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT SPARKS, OPEN FLAME
& AREAS WHERE STATIC ELEC (SUPP DATA)
=======================================================
Control Measures
=======================================================
Respiratory Protection: IN OPEN AREAS USE NIOSH/MSHA APPRVD MECH FILTER RESP TO
REMOVE SOLID AIRBORNE PARTICLES DURING SPRAY APPLICATION. IN RESTRICTED VENT
AREAS USE NIOSH/MSHA APPRVD CHEM-MECH FILTERS DESIGNED TO REMOVE A
COMBINATION OF PARTICULATES &
Ventilation: USE APPRVD SPRAY BOOTH. PROVIDE GENERAL DILUTION OR LOC EXHST VENT
IN VOL & PATTERN TO KEEP TLV OF MOST HAZ
Other Protective Equipment: PREVENT PROLONGED SKIN CONTACT WITH CONTAMINATED
CLOTHING.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: FIRE FIGHT PROC:AVOID UNNEC EXPOSURE TO FUMES.
ANY PERSON EXPOSED TO SUCH FUMES SHOULD RECEIVE IMMED MED ATTN. EXPLO HAZ:
MAY BE GENERATED. CLSD CNTNRS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT. WATER
MAY BE USED TO COOL CLSD CNTNRS. DO NOTAPPLY TO HOT SURFACES. DO NOT STORE
OR MIX WITH STRONG OXIDANTS.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: F3
B.P. Text: >241F,>116C
Vapor Pres: SEE INGS
Vapor Density: HVR/AIR
Spec Gravity: 1.44 (FP N)
Evaporation Rate & Reference: SLOWER THAN ETHER
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume: 31
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: TEMPS IN EXCESS OF 150F IN CLOSED CNTNR. EXPOSURE
TO HEAT, SPARKS, OPEN FLAME, HOT SURFACES.
Materials To Avoid: OXYGEN & STRONG OXIDANTS.
Hazardous Decomposition Products: CARBON DIOXIDE & CARBON MONOXIDE, OXIDES OF
LEAD AND CHROMIUM.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: Y-470, EPO-11 BP EPOXY SAFETY YELLOW
Cage: 0BDY9
Company Name: LENMAR, INC.
Street: 150 SOUTH CALVERTON ROAD
Zipcode: 21223
Label Required IND: Y
Date Of Label Review: 01/11/1994
Status Code: C
Label Date: 01/11/1994
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE LIQUID. OSHA CLASS IC. ACUTE: INHAL:
ANESTHETIC. IRRIT OF THE RESP TRACT OR ACUTE NERVOUS SYSTEM DEPRESSION
CHARACTERIZED BY HEADACHE, DIZZINESS, STAGGERING GAIT, CONFUSION,
UNCONSCIOUSNESS OR COMA. SKIN OR EYE: PRIMARY IRRITANT.INTENTIONAL MISUSE BY
DELIBERATELY CONC & INHALING THE CONTENTS MAY BE HARMFUL OR FATAL. LEAD
& LEAD COMPOUNDS APPEAR ON NAVY LIST OF OCCUP CHEM REPRODUCTIVE HAZ ARDS
(FP N). REPORTS HAVE ASSOCIATED REPEATED AND PROLONGED OCCUPATIONAL
OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:9C347 30 GAL DRUM, MIRACLE START
CAGE:58396
CAGE:58396
============= Composition/Information on Ingredients =============
Ingred Name:COCONUT OIL ACID DIETHANOLAMINE; (COCAMIDE DEA)
CAS:68603-42-9
RTECS #:GG6200000
Fraction by Wt: <2%
Other REC Limits:3 PPM (AS DEA)
Ingred Name:NONYLPHENOL POLYETHYLENE GLYCOL ETHER
CAS:127087-87-0
Fraction by Wt: <14%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC:EYES:MAY CAUSE REDNESS
AND IRRITATION. INGEST:MAY CAUSE NAUSEA, VOMITING AND DIARRHEA.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE TO FRESH AIR. CONSULT MD IF SYMPTOMS PERSIST.
INGEST:GIVE LARGE AMOUNTS OF WATER THEN SEVERAL GLASSES OF MILK.
INDUCE VOMITING. GET MD ATTENTION IMMEDIATELY. EYE:FLUSH
IMMEDIATELY WITH LARG E AMOUNTS OF WATER FOR AT LEAST 15 MINUTES
LIFTING EYELIDS OCCASIONALLY. GET MD ATTENTION IMMEDIATELY.
SKIN:RINSE THOROUGHLY WITH WATER.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:AS REQUIRED BY SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN LARGE SPILLS AND PUMP TO RECOVER.
SMALL SPILLS CAN BE MOPPED UP. FLUSH CONTAMINATED AREA WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP
CONTAINER CLOSED WHEN NOT IN USE. KEEP OUT OF REACH OF CHILDREN. DO
NOT USE WHILE CONSUMING FOOD OR BEVERAGE.
Other Precautions:DO NOT MIX CHEMICALS UNLESS SPECIFICALLY DIRECTED BY
LABEL DIRECTIONS. BE "PRODUCT KNOWLEDGABLE". READ DIRECTIONS PRIOR
TO USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED. USE NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:USE ADEQUATE VENTIALTION.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER USE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:V7
Boiling Pt:B.P. Text:>212F,>100C
Spec Gravity:1.00 (H2O=1)
Solubility in Water:100%
Appearance and Odor:CLEAR BLUE LIQUID WITH A NEUTRAL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND OXIDIZERS
Stability Condition to Avoid:EXTREME TEMPERATURES.
Hazardous Decomposition Products:CO, CO2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS & NATURAL/SYNTHETIC RUBBER COMPOSITION
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PDL X18-44-1
CAGE:1N060
CAGE:1N060
============= Composition/Information on Ingredients =============
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL, RATS) >5000 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: MAY CAUSE IRRITATION TO THROAT
& RESPIRATORY PASSAGES BUT AT ROOM TEMP, VAPOR INHALATION IS NOT
CONSIDERED HAZARDOUS. SKIN: THIS PROD CONTAINS AMINE CATALYST &
WILL CAUSE IRRIT AFTER PRLNG CONT . SOME INDIVIDUALS MAY BE MORE
SENSITIVE TO EXPOSURE. INGEST: THIS IS NOT CONSIDERED A COMMON
OCCUP (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: ROUTE OF EXPOSURE, AND NO OBSERVABLE
EFFECTS HAVE BEEN DEMONSTRATED.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/CLEAN/LUKE-WARM H*2O AT LOW PRESS FOR AT LST 15
MIN, OCCAS LIFTING EYELIDS. CONSULT MD IMMED. SKIN: REMOVE CONTAMD
CLTHG. WASH EXPOSED AREA W/WARM SOAPY H*2O THORO. CONTAMD CLTHG
SHLD BE PROPERLY WASHED BEFORE REUSING. INHAL:NOT CONSIDERED HAZ
IN AN INDUS SITUATION. REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE
O*2/ARTF RESP) . INGEST: INDUCE VOMIT. NEVER GIVE ANYTHING (SUPP
DATA)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:248F,120C
Extinguishing Media:DRY CHEM EXTING SUCH AS MONOAMMONIUM PHOSPHATE/
POTASSIUM SULFATE/POTASSIUM CHLORIDE. ADDITIONALLY, CO*2, (SUPP
DATA)
Fire Fighting Procedures:DO NOT DIRECT SOLID WATER STREAM/FOAM INTO
HOT/ BURNING POOLS; THIS MAY CAUSE FROTHING & INCREASE FIRE
INTENSITY. USE NIOSH/MSHA APPRVD SCBA & FULL (SUPP DATA)
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILLED MATL & THEN COVER W/A LOOSE,
ABSORBANT MATL SUCH AS OILDRY, VERMICULITE, SAWDUST OR FULLER'S
EARTH. SHOVEL WASTE MATL INTO PROPER WASTE CONTRS. WASH CONTAMD
AREAS W/HOT SOAPY WATER THO ROUGHLY. VENTILATE AREA TO REMOVE
VAPORS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:IF CONTAM W/ISOCYANATES IS SUSP, DO
NOT RE-SEAL CONTR BECAUSE OF POSS RUPTURE DUE TO PRESS BUILDUP.
ALWAYS SLOWLY VENT CONTR WHEN OPENING (SUPP DATA)
Other Precautions:STORAGE TEMP (MIN/MAX): 65F(18C) TO 75F(24C). AVG
SHELF LIFE: 6 MOS FROM DATE OF MFG. SPECIAL SENSITIVITY
(HEAT/LIGHT/MOISTURE): THIS PROD IS HYGROSCOPIC. CONTRS SHLD BE
TIGHTLY SEALED TO PVNT MOISTUR E CONTAM. DO NOT EXPOSE TO HIGH (ING
5)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:PROD HAS DEMONSTRATED NO OBSERVABLE EFTS @ RM
TEMP. HOWEVER, IT IS HIGHLY RECOMMENDED THAT A NIOSH/MSHA APPRVD
AIR PURIFYING RESP W/ORGANIC FILTER CARTRIDGES BE WORN. IN ADDN, IN
ANY SPRAY APPLICATN, A SUPPLIED AIR SOURCE MUST BE PROVIDED.
Ventilation:NATURAL/MECH. LOCAL EXHST WILL KEEP TLV BELOW MIN IN MOST
CASES. SPILLS/OTHER EMER MAY REQ MORE FORCEFUL VENT MEANS.
Other Protective Equipment:COVER AS MUCH EXPOSED SKIN AS POSS W/APPROP
CLTHG. IF SKIN CREAMS ARE USED, KEEP AREA COVERED BY THE CREAM TO A
(ING 3)
Work Hygienic Practices:NO CONTACT LENSES SHLD BE WORN. WASH CONTAMD
CLTHG BEFORE REUSE.
Supplemental Safety and Health
EXTING MEDIA: HIGH EXPANSION (PROTEINIC) CHEM FOAM, WATER SPRAY FOR LG
FIRES. FIRE FIGHT PROC: PROT EQUIP . BURNING CAN PRDCE CO*X/NO*X.
FIRST AID PROC: TO DRINK TO AN UNCON PERSON OR INDUCE VOM IT IN AN
UNCON PERSON. NOTE TO MD: BASICALLY, TREATMENT IS SYMPTOMATIC.
HNDLG/STOR PREC: TO RELIEVE ANY PRESS BUILDUP.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:DECOMPOSES
Melt/Freeze Pt:M.P/F.P Text:<32F,<0C
Vapor Pres:NIL
Vapor Density:>1
Spec Gravity:1.07
Solubility in Water:SLIGHTLY SOLUBLE
Appearance and Odor:VISCOUS LIQUID, CLEAR TO AMBER COLOR, SLIGHT
AMMONIA ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/ISOCYANATES AND OTHER SUBSTANCES THAT REACT W/HYDROXYL
GROUPS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:ALIPHATIC FRAGMENTS, CO, NH*3, CO*2
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MATL MAY BE INCINERATED OR DISPOSED OF
UNDER LOCAL, STATE AND FEDERAL REGULATIONS CONTROLLING
ENVIRONMENTAL PROTECTION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PRO CARE ONE STEP DISINFECTANT
CAGE:FXRMA
CAGE:FXRMA
============= Composition/Information on Ingredients =============
Ingred Name:NONYLPHENOL POLYETHOXATE; (NONYL PHENOL ETHOXYLATE)
CAS:9016-45-9
RTECS #:MD0900000
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHYLBENZENE AMMONIUM CHLORIDE; (N-ALKYL
DIMETHYLETHYLBENZENE AMMONIUM CHLORIDE)
CAS:68956-79-6
Fraction by Wt: 2.25%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:N-ALKYL DIMETHYLBENZYL AMMONIUM CHLORIDE (MFR INVALID CAS #
68371-01-5)
CAS:68371-01-5
Fraction by Wt: 2.25%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: CAUSES SEVERE CHEMICAL
BURNS. MAY CAUSE BLINDNESS. SKIN: MAY CAUSE CHEMICAL BURNS.
INGESTION: HARMFUL OR FATAL. CAUSES CHEMICAL BURNS TO MOUTH, THROAT
AND STOMACH. INHALATION: PRODUCT MIS T MAY DAMAGE AIRWAYS AND
LUNGS, DEPENDING ON THE EXTENT OF THE EXPOSURE. CHRONIC: NONE
SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PEOPLE WITH LUNG OR RESPIRATORY
PROBLEMS MAY BE MORE SENSITIVE.
======================= First Aid Measures =======================
First Aid:EYES: IMMED FLUSH W/WATER FOR AT LEAST 15 MIN. REMOVE CONT
LENSES, CONTINUE FLUSHING FOR AT LEAST 15 MIN. CALL MD IMMED. SKIN:
FLUSH W/WATER FOR 15 MIN WHILE REMOVING ANY CONTAM CLTHG. WASH
CLTHG BEFO RE REUSE. INGEST: RINSE MOUTH; THEN DRINK 1-2 GLASSES OF
MILK, EGG WHITES/GELATIN SOLN; IF THESE ARE NOT AVAIL, DRINK LGE
QTYS OF WATER. AVOID USE OF ALCOHOL. INHAL: IMMED MOVE TO FRESH
AIR. (SUP DAT)
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:PRODUCT DOES NOT SUPPORT COMBUSTION. USE MEDIA
SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE OR DAM LARGE SPILLS. PUMP TO CONTAINERS
OR SOAK UP ON INERT ABSORBENT. FLUSH RESIDUE TO SANITARY SEWER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. ALWAYS
KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:USER OF ANY CHEM PRODS SHOULD BE AWARE OF POTENTIAL
HAZS, KNOWN & UNKNOWN, & THEIR EFT ON HUMAN SYS. MFR STRONGLY URGES
THAT ALL USERS MINIMIZE THEIR EXPOS TO ALL CHEMS, INCL THIS PROD &
TO KEEP LEVEL OF EXPOS COMMENSURATE WITH (SUP DAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID BREATHING MISTS OR VAPORS FROM THIS
PRODUCT. USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF
CONCERN .
Ventilation:LOCAL EXHAUST: TO MAINTAIN ADEQUATE VENTILATION.
MECHANICAL: NOT REQUIRED.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: IN CASE OF A MEDICAL EMERGENCY CALL MD OR POISON
CONTROL CENTER. OTHER PREC: GOOD INDUSTRIAL HYGIENE PRACTICES. EYE
PROTECTION: AND FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:1.04
pH:11-12
Evaporation Rate & Reference:1 (WATER=1)
Solubility in Water:SOLUBLE
Appearance and Odor:COLORLESS LIQUID WITH A CHARACTERISTIC ODOR
Percent Volatiles by Volume:>80
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, CHLORINE. MIX WITH WATER ONLY!
Stability Condition to Avoid:MIX ONLY WITH WATER.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE WITH ALL STATE, LOCAL AND FEDERAL
REGULATIONS. RINSE EMPTY CONTAINER THOROUGHLY BEFORE DISCARDING.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:F-8010, FIRST CLASS LEMON FURNITURE POLISH
CAGE:PUREX
CAGE:PUREX
CAGE:0BYN5
============= Composition/Information on Ingredients =============
Ingred Name:NON HAZARDOUS INGREDIENTS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES:SLIGHT IRRITANT. INHAL:NO
EFFECTS OF EXPOSURE EXPECTED. INGEST:SLIGHTLY TOXIC.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NO DATA AVAILABLE.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN:FLUSH
WITH WATER. INHAL:NO EFFECTS OF EXPOSURE EXPECTED. REMOVE FROM
EXPOSURE. SUPPORT BREATHING (GIVE ARTIFICIAL RESPIRATION/O*2) .
INGEST:GI VE SEVERAL GLASSES OF WATER OR MILK. CALL MD .
===================== Fire Fighting Measures =====================
Flash Point:SUPDAT
Extinguishing Media:FOAM, CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . COOL AEROSOL UNITS IN AREA OF A FIRE OR
EXCESSIVE HEAT.
Unusual Fire/Explosion Hazard:TEMPERATURES OVER 120F MAY CAUSE AEROSOL
CANS TO BURST.
================== Accidental Release Measures ==================
Spill Release Procedures:CONCENTRATE/SOLUTION:MOP UP SPILLAGE WITH
ABSORBENT MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NORMAL HANDLING PROCESSES; INSIDE
STORAGE AT 40-100F RECOMMENDED.
Other Precautions:A PROGRAM OF REGULAR CLEANING, REPAIRING AND
REPLACING OF WORN-OUT PARTS AND CONTAMINATED EQUIPMENT IS HIGHLY
DESIRABLE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED. USE NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NORMAL VENTILATION.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:USE ADEQUATE WASHING FACILITIES. WASH HANDS AND
OTHER CONTACT AREAS THOROUGHLY. CHANGE CLOTHING IF WETTED WITH
(SUPDAT)
Supplemental Safety and Health
FLASH POINT:OVER 18" FLAME PROJECTION. HYGIENE PRACT:PRODUCT. DO NOT
REUSE CLOTHING WETTED WITH PRODUCT BEFORE CLOTHING IS LAUNDERED.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:0.87
pH:7-8
Evaporation Rate & Reference:1 (WATER = 1)
Solubility in Water:97%
Appearance and Odor:WHITE EMULSION WITH SOLVENT LEMON ODOR.
Percent Volatiles by Volume:97
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:CONCENTRATE, SPENT SOLUTION AND RINSES:DISPOSE
OF AEROSOL UNITS IN NON-INCINERATED TRASH IN ACCORDANCE WITH LOCAL,
STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ULTRATHENE, UE64904
Resp. Party Other MSDS Num.:UL 1A/UE64904
CAGE:TO422
CAGE:TO422
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE-VINYL ACETATE COPOLYMER LD50: (ORAL, RAT) >1,000
MG/KG
CAS:24937-78-8
> Wt:99.
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EMERGENCY OVERVIEW: APPROXIMATELY 1/8
- 3/8" CLEAR TO TRANSLUCENT SOLID PLASTIC PELLETS W/SLIGHT ESTER
ODOR. DOES NOT CONTAIN MATERIALS WHICH MAY CONTRIBUTE TO IMMEDIATE
HEALTH, PHYSICAL OR ENVIRONMEN TAL HAZARDS. POTENTIAL HEALTH
EFFECTS OF THIS POLYMER: IN SOLID FORM, THIS POLYMER IS NOT
CONSIDERED TO BE A HEALTH HAZARD, ALTHOUGH THE PELLETS AND THE
DUSTS GENERATED FROM THEM MAY BE MILDLY IRRITAT ING TO THE SKIN AND
EYES BY MECHANICAL ACTION. IF SWALLOWED, POLYMER MAY POSE POSSIBLE
INTESTINAL OBSTRUCTION. DUST CREATED DURING HANDLING OR PROCESSING
MAY BE MILDLY IRRITATING TO THE RESPIRATORY SY STEM. (EFFECTS OF
OVEREXPOSURE)
Effects of Overexposure:HEALTH HAZARDS: WHEN HEATED, THIS POLYMER MAY
RELEASE FUMES AND/OR VAPORS THAT ARE IRRITATING TO THE EYES, NOSE,
THROAT AND SKIN. OVEREXPOSURE TO FUMES OR VAPORS MAY ALSO CAUSE
HEADACHE, NAUSEA, SHORT NESS OF BREATH AND COUGH. MOLTEN OR HEATED
MATERIAL CAN CAUSE SERIOUS BURNS TO UNPROTECTED SKIN AND EYES.
ALSO, SEE TOXICOLOGICAL INFO (SECTION 11) AND ECOLOGICAL INFO
(SECTION 12).
Medical Cond Aggravated by Exposure:THERE ARE NO KNOWN MED CNDTNS
AGGRAVATED BY EXPOS TO PROD. HOWEVER, CERTAIN SENSITIVE INDIVIDUALS
& INDIVIDUALS W/RESP IMPAIRMENTS MAY BE AFFECTED BY EXPOS TO
COMPONENTS IN THE PROCESSING EMISSIONS.
======================= First Aid Measures =======================
First Aid:INGEST: IF PROD INGESTED, CONTACT MD OR POISON CONTROL CENTER
AS APPROP WHENEVER ANY FOREIGN OBJECT IS SWALLOWED. SKIN: IF
CONTACTED BY MOLTEN POLYMER, COOL IMMED W/COLD OR ICE WATER. DO NOT
ATTEMPT R EMOVAL OF ANY SOLIDIFIED MATL. GET MED ATTN PROMPTLY.
EYES: IF CONTACT BY MOLTEN POLYMER, IMMED FLUSH EYES W/PLENTY OF
COOL WATER FOR AT LEAST 15 MIN. DO NOT PERMIT VICTIM TO RUB EYES.
GET MED ATTN IM MED. INHAL: IMMED REMOVE VICTIM TO FRESH AIR. IF
VICTIM HAS STOPPED BRTHG GIVE ARTF RESP, PREFERABLY MOUTH-TO-MOUTH.
GET MED ATTN IMMED. NOTE TO MD: IN CASE OF MOST BURNS, ALLOW
SOLIDIFIED MATL TO SLO UGH OFF ON ITS OWN. ATTEMPTED (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:DOES NOT APPLY
Extinguishing Media:USE WATER SPRAY, DRY CHEMICAL, FOAM OR CARBON
DIOXIDE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . IF POSSIBLE, WATER SHOULD BE APPLIED AS A SPRAY FROM A
FOGGING NOZZLE SINCE THIS POLYMER IS SURFACE BURNING MATERIAL.
(NOTE: INDIVIDUALS S HOULD PERFORM ONLY THOSE FIRE-FIGHTING
PROCEDURES FOR WHICH THEY HAVE BEEN TRAINED.)
Unusual Fire/Explosion Hazard:KNOWN OR ANTICIPATED PRODUCTS OF
COMBUSTION: CARBON MONOXIDE IS THE PRIMARY HAZARDOUS COMBUSTION
PRODUCT (SEE ALSO STABILITY AND REACTIVITY SECTION). NFPA RATING:
NO NFPA RATING AVAILABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:ENVIRONMENTAL PRECS: AVOID UNCONTROLLED
RELEASES OF MATL. WHERE SPILLS ARE POSS, COMPREHENSIVE SPILL RELS
RESPONSE PLAN SHOULD BE DEVELOPED & IMPLEMENTED. PLASTIC PELLETS
ARE LISTED AS "SIGNIFICANT MA TLS" BY US EPA (40 CFR 122.26
(B)(12)) & MAY NEED TO BE DISCUSSED IN AN APPLICATION FOR STORM
WATER DISCHARGE PERMIT. ACCIDENTAL RELS PROCS: USE GOOD
HOUSEKEEPING PRACTICES SINCE (TOXICOLOGICAL INFO)
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN DRY PLACE AWAY FROM MOISTURE,
EXCESSIVE HEAT AND SOURCES OF IGNITION.
Other Precautions:HANDLING OF PELLETS IN BOTH LOADING & UNLOADING
OPERATIONS AS WELL AS FABRICATION MAY CAUSE DUST TO BE FORMED &
NECESSARY PRECS FOR PERSONAL PROTECTION (SEE EXPOSURE CONTROLS,
PERSONAL PROTECTION) SHO ULD BE USED. WHEN TRANSFERRING PELLETS,
PRECS SUCH AS GROUNDING & BONDING CAN PREVENT BUILD-UP OF ST ATIC
ELECTRICITY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN ENGINEERING CONTROLS ARE NOT FEASIBLE OR
SUFFICIENT TO ACHIEVE FULL CONFORMANCE WITH ACCEPTABLE EXPOSURE
LIMITS (INGREDIENT SECTION), USE NIOSH APPROVED RESPIRATORY
PROTECTION EQUIPMENT. RESPIRAT ORS SHOULD BE SELECTED BASED ON THE
FORM AND CONCENTRATION OF CONTAMINANT(S) IN AIR AND I/A/W OSHA (29
CFR 1910.124) / ANSI STANDARD Z88.2
Ventilation:ENGINEERING CTLS SHOULD BE USED WHENEVER FEASIBLE TO
MAINTAIN CONCS BELOW ACCEPTABLE EXPOS LIMS INCL, BUT NOT LIMITED
TO, ENCLOSURES, LOC VENT & DILUTION VENT.
FACESHIELD .
Other Protective Equipment:ANSI APPROVED EYE WASH AND DELUGE SHOWER .
WEAR HEAT PROTECTIVE CLOTHING IF THERE IS A POTENTIAL FOR CONTACT
WITH HEATED MATERIAL.
Supplemental Safety and Health
FIRST AID PROC: REMOVAL MAY LEAD TO MORE DMG OF SKIN & UNDERLYING TISS.
IF REMOVALINDICATED (EG, SOLIDIFIED MATL IS LOCATED ON CRITICAL
PART OF HAND/FACE), REMOVAL W/MINERAL OIL RECOM. DUE TO EXTREM ELY
HIGH TEMP OF MOLTEN POLYMER AT TIME OF CNTCT, BACTERIAL INFECTION
UNDER SOLIDIFIED MATL IS UNLIKELY TO BE PRESENT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:DOES NOT APPLY
Melt/Freeze Pt:>57.8C, 136.F
M.P/F.P Text:136-244F(58-112C)
Vapor Pres:DOES NOT APPLY
Spec Gravity:0.92-0.95 G/CC @ 25C
Solubility in Water:INSOLUBLE
Appearance and Odor:APPROX 1/8-3/8" CLEAR TO TRANSLUCENT SOLID PLASTIC
PELLETS W/SLIGHT ESTER ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY BURN OR REACT VIOLENTLY WITH FLUORINE/OXYGEN MIXTURES WITH 50 TO
100% FLUORINE. MAY BE DECOMPOSED BY STRONG OXIDIZING AGENTS SUCH AS
NITRIC AND SULFURIC ACIDS, HALOGENS, HYDROGEN PEROXIDE AND
CHLORINATING AGENTS.
Stability Condition to Avoid:GENERALLY STABLE BELOW OR WITHIN
RECOMMENDED PROCESSING CONDITIONS.
Hazardous Decomposition Products:UNDER CERTAIN CNDTNS, THERMAL DECOMP
PRODS HAVE BEEN REPORTED. THEY MAY INCL, BUT ARE NOT LIMITED TO,
CARBON, OXIDES OF CARBON, OXIDES OF NITROGEN, VINYL ACETATE, WATER,
ACROLEIN, (TRANSPORT INFO)
=================== Toxicological Information===================
Toxicological Information:TOXICOLOGICAL INFO (FROM THE LITERATURE) FOR
THIS POLYMER - ETHYLENE VINYL ACETATE COPOLYMER: ACUTE DATA: LC50:
(INHAL, RAT) NO DATA AVAILABLE. LD50: (SKIN, RABBIT) NO DATA
AVAILABLE. LD50: (ORAL, RAT ) >1,000 MG/KG. SPILL PROC: SPILLED
PELLETS MAY BE SLIPPING HAZ. WEAR APPROP NIOSH APPRVD RESP PROT &
PROT CLTHG AS DESCRIBED IN EXPOSURE CONTROLS, PERSONAL PROTECTION.
CNTN SPILLED MATL. TRANSFER T O SECURE CNTNRS. IN EVENT OF
UNCONTROLLED RELEASE OF THIS MATL, USER SHOULD DETERMINE IF RELEASE
IS REPORTABLE UNDER APPLICABLE LAWS & REGS.
===================== Ecological Information =====================
Ecological:ENVIRONMENTAL FATE INFORMATION (FROM THE LITERATURE) FOR
THIS POLYMER: THIS MATERIAL IS GENERALLY INERT AND INSOLUBLE AND IS
NOT EXPECTED TO HAVE ANY ADVERSE EFFECT ON THE ENVIRONMENT. THIS
MATERIAL M AY DETERIORATE BY A NUMBER OF MECHANISMS INCLUDING
PHOTO- AND THERMO-OXIDATIVE DEGRADATION. PHOTODEGRADED POLYMERS ARE
ALSO MORE EASILY BIODEGRADED. ECOTOXICITY DATA (FROM THE
LITERATURE) FOR THIS POL YMER: NO DATA AVAILABLE ON THIS PRODUCT.
HOWEVER, BIRDS, FISH AND OTHER WILDLIFE MAY EAT PELLETS WHICH MAY
OBSTRUCT THEIR INTESTINAL TRACTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:ALL RECOVERED MATL SHOULD BE PACKAGED, LABELED,
TRANSPORTED & DISPOSED OF OR RECLAIMED IN CONFORMANCE W/APPLIC FED,
STATE & LOCAL LAWS & REGS & IN CONFORMANCE W/GOOD ENGINEERING
PRACS. RECLAIM WHERE P OSS. INFO PROVIDED IN MSDS APPLIES ONLY TO
PROD AS MANUFACTURED BY EQUISTAR CHEMS, LP. PROCESSING, U SE &
CONTAM MAY MAKE THIS INFO (TRANSPORT INFO)
=================== MSDS Transport Information ===================
Transport Information:DEPARTMENT OF TRANSPORTATION (DOT): NOT REGULATED
BY DOT AS A HAZ MATL. WASTE DISP METH: INAPPROP FOR MATL
REQUIRING DISP. STATE & LOCAL LAWS & REGS MAY DIFFER FROM FED REQS
& REQS MAY CHANGE OR BE RE-INTERPRETED. IT IS RESPONSIBILITY OF
WASTE GENERATOR TO CHARACTERIZE WASTE STREAMS RELATIVE TO PERTINENT
REGULATORY PROVISIONS (INCL RCRA "CHARACTERISTIC" WASTE DEFINITIONS
40 CFR 261 SUBPART C) TO ENSURE APPLIC REQS ARE REVIEWED & MET.
HAZ DECOM PRODS: FORMALDEHYDE, OTHER ALDEHYDES, KETONES, ALCOHOLS,
ACETIC ACID, FATTY ACIDS, METHANE, ETHANE, ACETYLENE, OTHER ORGANIC
VAPS & FUMES (SEE ALSO FIRE FIGHT MEASURES).
===================== Regulatory Information =====================
SARA Title III Information:SARA TITLE III (SECTIONS 311/312) HAZ
CATEGORIES: THIS PROD DOES NOT MEET CRITERIA OF ANY HAZ CATEGORIES.
SARA TITLE III (SECTION 313): PROD CNTNS NO SARA 313 "TOX CHEMS"
ABOVE THRESHOLD LEVELS. STA TE REG INFO: THESE CHEMS CONSIDERED
TO BE IMPURITIES OR CONTAMINANTS.OTHER INFO: REGULATED (DUST): 5
MG/M3 FOR RESPIRABLE DUST. TLV/TWA (ACGIH THRESHOLD LIM
VALUE/TIME-WEIGHTED AVERAGE): NO ACGIH T LV FOR THIS MIX. FOR
PARTICULATES NOT OTHERWISE CLASSIFIED (DUST): 10 MG/M3 FOR TOTAL
DUST & 3 MG/M3 FOR RESPIRABLE DUST. ADDITIVES (IF ANY PRESENT) IN
PROD ARE ENCAPSULATED IN THERMOPLASTIC RESIN W/L IMITED RELS UNDER
NORM (FED REG INFO)
Federal Regulatory Information:TOX SUBSTANCE CTL ACT (TSCA): PROD IS
(OR IF MIX, COMPONENTS OF PROD ARE) LISTED IN TSCA INVENTORY OF
CHEM SUBSTANCES. NOTE: REG INFO PRESENTED HERE SHOULD NOT
NECESSARILY BE CONSIDERED AS ALL-INCLUSI VE. OTHER LOC, STATE, FED
& INTERNATL REGS MAY ALSO APPLY. SARA REG INFO: CNDTNS OF USE,
TRANSPORT & STOR. INCREASED RELS MAY OCCUR WHEN RESIN (OR MATL/PROD
MANUFACTURED FROM IT) IS SUBJECT TO GRIND ING, POLISHING, EXCESS
HEAT OR OTHER PROCESSES WHICH ENHANCE POTNTL FOR GENERATION OF
PARTICULATES, FUMES &/OR VAPS. SPECIFIC POTNTL FOR RELS UNDER
USER'S CNDTNS OF HNDLG THIS MATL SHOULD BE EVALUATED BY QUALIFIED
HLTH SPECIALIST.
State Regulatory Information:CA PROP 65: PROD DOES NOT CNTN ANY INGREDS
WHICH ARE LISTED UNDER THIS STATE LAW. HOWEVER, MAY BE
NATURALLY-OCCURRING CONTAMINANTS OR UNINTENTIONALLY-INTRODUCED
IMPURITIES THAT APPEAR IN RAW MATLS OR MFG PROCESS USED TO PRDCE
PROD. WHILE MFR DOES NOT ROUTINELY ANALYZE THEIR PRODS OR SUPPLIER
RAW MATLS FOR SUCH IMPURITIES & CONTAMINANTS, POSSIBILITY OF THEIR
PRESENCE IN TRACE QTYS EXISTS. TO COMPLY W/CA LAW, MFR PROVIDES
FOLLOWING STATEMENT: WARNING: PROD CNTNS (OR MAY CNTN) TRACE AMTS
OF CHEM (O R CHEMS) KNOWN TO STATE OF CA TO CAUSE CANCER, BIRTH
DEFECTS &/OR OTHER REPRO HARM. IF PRESENT (SARA REG INFO)
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:106 0607 EASTMAN ECN-2/ECP-2B KIT STOP BATH, CONCENTRATE
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROGEN SULFATE
CAS:7681-38-1
RTECS #:VZ1860000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT)MALE:1903MG/KG,F:1345MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:AIRBORNE DUST IRRIT.MAY CAUSE
IRRIT TO MUC MEMBRANES & UPPER RESP TRACT. EYE:CAUSES SEVERE BURNS.
SKIN:CAUSES IRRIT. INGEST:HARMFUL IF SWALLOWED.MAY CAUSE BURNS OF
GASTROINTESTINAL TRACT IF SWAL LOWED.
Explanation of Carcinogenicity:PER MSDS:CARCINOGENICITY
CLASSIFICATION:IARC/ACGIH/NTP/OSHA:NONE.
Effects of Overexposure:IRRIT MUCOUS MEMBRANES, UPPER RESPIRATORY
TRACT, SKIN. BURNS EYES, GASTROINTESTINAL TRACT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE TO FRESH AIR.TREAT SYMPTOMATICALLY.GET MED ATTN IF
SYMPTONS PERSIST. EYES:IMMED FLUSH W/PLENTY OF WATER FOR @LEAST
15MINS.GET MED ATTN. SKIN:IMMED FLUSH W/PLENTY OF WATER FOR @LEAST
15MINS WHILE REMOVING CONTAIN CLOTH/SHOES.GET MED ATTN. INGEST:DO
NOT INDUCE VOMIT.GIVE VICTIM A GLASS OF WATER.NEVER GIVE ANYTHING
BY MOUTH IF UNCONSC.CALL DR/POIS CNTNRL CENTER IMMED.
===================== Fire Fighting Measures =====================
Flash Point:N/APPLICABLE
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE. NON-COMBUSTIBLE SOLID.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER W/LG AMTS OF WATER. CLEAN
SURFACE THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT GET IN EYES.AVOID BREATH
DUST.AVOID CONTACT W/SKIN.USE W/ADEQUATE VENTI.KEEP CNTNR CLSD.KEEP
AWAY FRM INCOMP MATLS.
Other Precautions:PROPERTIES:NO BIOCHEM OXY DEMAND;NO POT TO CAUSE OXY
DEPLETION IN AQU SYS;LOW POT TO AFFECT AQU ORGANISMS & 2ND WASTE
TREATMENT MICROBIAL METABOLISM;LOW POT TO AFFECT GERM &/OR EARLY
GROWTH OF SOME PL ANTS & BIOCONC.MATL RELEASED (SUP)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS DO NOT MAINTAIN AIRBORNE
CONCEN TO ACCEPTABLE LEVEL APPORVED RESP MSUT BE WORN.RESP
TYPE:DUST.IF RESP USED PROGRAM SHOULD BE INSITUTED TO ASSURE
COMPLIANCE W/OSHA STD 29 CFR 19 10.134.
Ventilation:USE GOOD GEN VENTI(10 AIR CHANGES/HR).MATCH RATES
W/CONDITIONS.SUPPLEMENTARY LOC EXHAU VENTI/CLSD SYS/RESP PROT
(SUPPLE)
Other Protective Equipment:IMPERVIOUS BOOTS,PROTECTIVE CLOTH
APPROPRIATE FOR RISK OF EXPOSURE. EYEBATH, WASHING FACILITIES,
SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS WELL AFT HNDLG.
Supplemental Safety and Health
OTHER PRECAUT:DIR/INDIR INTO ENVIRO NOT EXPECTED TO HAVE SIGNIFICANT
IMPACT. VENTI:MAY BE NEEDED IN SPEC CIRCUMST(POORLY VENTI
SPACES,MECHANICAL GENERATION DUST/HEAT/DRY/ETC). SEE PNIND:W FOR
WORKING SOLN. KEY:HCC:C1.
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:N/APPLICABL
Melt/Freeze Pt:M.P/F.P Text:138F,59C
Vapor Pres:NEGLIGIBLE
Vapor Density:N/APPLICAB
Spec Gravity:2.103
pH:N/APPL
Solubility in Water:COMPLETE
Appearance and Odor:SOLID, WHITE, ODORLESS
Percent Volatiles by Volume:N/APPL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HALOGENATED MATERIALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:SULFUR DIOXIDE. HAZ COMBUST PROD:NONE
(NON-COMBUSTIBLE).
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE/TREATMENT/DISPOSAL MAY BE SUBJECT TO
NATIONAL/STATE/LOCAL LAWS. FLUSH TO SEWER W/LG AMTS OF WATER. CHEM
SUBJ TO REPORTING REQMTS SEC 313 TITLE III SARA/40CFR PART
372:NONE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:F151R66,HAZE,GRAY,COMP A, TYPE II
Kit Part:Y
CAGE:1HK86
CAGE:1HK86
============= Composition/Information on Ingredients =============
Ingred Name:AMINE COMPOUND
Fraction by Wt: 20%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9394
Ingred Name:TALC
CAS:14807-96-6
RTECS #:MW2700000
Fraction by Wt: 35%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:0.2 FIBERS/CC; 9394
Ingred Name:N-BUTYL ALCOHOL (SARA III)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9394
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-ETHOXYETHANOL (EGEE) (SARA III)
CAS:110-80-5
RTECS #:KK8050000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S,200 PPM
ACGIH TLV:S, 5 PPM; 9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VM&P NAPHTHA
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:300 PPM
ACGIH TLV:300 PPM; 9394
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CHRONIC: REPORTS HAVE ASSOCIATED
REPEATED AND PROLONGED OCCUPATIONAL EXPOSURE TO SOLVENTS WITH
PERMANENT BRAIN DAMAGE AND NERVOUS SYSTEM DAMAGE. PROLONGED OR
REPEATED BREATHING OF SPRAY MIST AND/OR SA NDING DUST OVER A PERIOD
OF YEARS MAY CAUSE DUST DISEASE OF THE LUNGS.
Explanation of Carcinogenicity:NOT APPLICABLE.
Effects of Overexposure:BREATHING-IRRITATION OF THE RESPIRATORY TRACT;
HEADACHE, NAUSEA, DIZZINESS & FATIGUE. EXTREME EXPOSURE CAN RESULT
IN UNCONSCIOUSNESS & EVEN RESPIRATORT ARREST. SKIN OR EYE-CAUSES
EYE AND SKIN IRRITATI ON. SWALLOWING-CAN CAUSE STOMACH &/OR
INTESTINAL IRRITATION, NAUSEA, VOMITING AND DIARRHEA.
Medical Cond Aggravated by Exposure:NONE, WHEN USED IN ACCORDANCE WITH
SAFE HANDLING AND USE INFORMATION.
======================= First Aid Measures =======================
First Aid:BREATHED-IF HARD TO BREATHE, MOVE TO FRESH AIR. IF CONTINUED
DIFFICULTY IS EXPERIENCED, SUMMON MEDICAL ASSISTANCE IMMEDIATELY.
IF BREATHING CEASES, RESTORE USING APPROVED CPR TECNIQUES.
EYES-FLUSH IMM EDIATELY WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MIN. GET MEDICAL ASSISTANCE. SKIN-WASH AFFECTED AREA WITH SOAP &
WATER. SWALLOWED-CONSULT A PHYSICIAN IMMEDIATELY. DO NOT INDUCE
VOMITING.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:90.0F,32.2C
Lower Limits:0.9
Extinguishing Media:IN CASE OF FIRE USE CARBON DIOXIDE, DRY CHEMICAL,
FOAM OR OTHER NFPA APPROVED METHOD FOR TREATING A CLASS B FIRE.
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIPMENT INCLUDING
SELF-CONTAINED BREATHING APPARATUS. WATER SPRAY MAY BE INEFFECTIVE.
IF WATER IS USED, FOG NOZZLE PREFERABLE.
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT,
SPARKS AND FLAME. DUE TO PRESSURE BUILDUP, CLOSED CONTAINERS
EXPOSED TO EXTREME HEAT MAY EXPLODE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. PREVENT
BREATHING OF VAPORS. VENTILATE AREA. BEFORE ATTEMPTING CLEAN-UP,
REFER TO HAZARD CAUTION INFORMATION IN OTHER SECTIONS OF THIS
MSDS. CONTAIN SPILLED MATERIAL & REMOVE WITH INERT ABSORBENT &
NONSPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS AND
FLAMES. DO NOT SMOKE. PREVENT BUILD-UP OF VAPORS BY MAINTAINING
CONTINUOUS FLOW OF FRESH AIR.
Other Precautions:DO NOT STORE ABOVE 120 DEGREES F OR NEAR FIRE OR OPEN
FLAME. STORE LARGE QUANTITIES IN BUILDINGS TO COMPLY WITH OSHA
1910.106. KEEP CONTAINERS CLOSED WHEN NOT IN USE. DO NOT TRANSFER
CONTENTS TO BOTTL ES OR OTHER UNLABELLED CONTAINERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DO NOT BREATHE VAPORS, SPRAY MIST OR SANDING
DUST. WHEN SPRAY APPLIED IN OUTDOOR OR OPEN AREAS, & DURING SANDING
OR GRINDING OPERATIONS, USE NIOSH/MSHS APPROVED MECHANICAL FILTER
RESPIRATOR TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY.
Ventilation:PROVIDE GENERAL DILUTION OR LOCAL EXHAUST VENTILATION IN
VOLUME & PATTERN TO KEEP AIR CONTAMINANTS BELOW SAFETY STANDARD
Other Protective Equipment:DO NOT GET ON SKIN. SOLVENT IMPERMEABLE
CLOTHING & BOOTS TO PREVENT SKIN CONTACTS ARE RECOMMENDED.
Work Hygienic Practices:REMOVE AND WASH SOLIED CLOTHING BEFORE REUSE.
WASH HANDS BEFORE EATING OR SMOKING
Supplemental Safety and Health
DO NOT REUSE EMPTY CONTAINERS. IF THIS MATERIAL IS PART OF A TWO
COMPONENT PRODUCT, THEN THE MIXTURE OF BASE AND CONVERTER PROTIONS
WILL HAVE HAZARDS OF BOTH COMPONENTS. WARNING: THIS PRODUCT MAY
CONT AIN A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER, BIRTH DEFECTS, OR OTHER REPRODUCTIVE HARM.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:153-275F
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER.
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:53.48
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY CAUSE TOXIC FUMES WHEN HEATED TO
DECOMPOSITION. FUMES MAY CONTAIN CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGN
==================== Disposal Considerations ====================
Waste Disposal Methods:STORE IN CLOSED CONTAINER UNTIL PROPERLY
DISPOSED OF. DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS. INCINERATE ONLY IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SKIN SHIELD 2, 2245
CAGE:EO366
CAGE:EO366
CAGE:6P489
============= Composition/Information on Ingredients =============
Ingred Name:GLYCERIN
CAS:56-81-5
RTECS #:MA8050000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 (MIST) 9293
Ingred Name:CELLULOSE; (CELLULOSE GUM)
CAS:9004-34-6
RTECS #:FJ5691460
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3
Ingred Name:GLYCOL DERIVATIVE; (GLYCOL DISTEARATE)
Ingred Name:PEG-50 STEARATE
Ingred Name:BENZOIC ACID, P-HYDROXY-, METHYL ESTER; (METHYLPARABEN)
CAS:99-76-3
RTECS #:DH2450000
Ingred Name:BENZOIC ACID, P-HYDROXY, PROPYL ESTER; (PROPYL PARABEN)
CAS:94-13-3
RTECS #:DH2800000
Ingred Name:FRAGRANCE (PROPRIETARY BLEND)
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT MAY RESULT IN IRRITATION
OF EYES.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH THOROUGHLY WITH WATER, LIFTING UPPER AND LOWER
EYELIDS OCCASIONALLY. SKIN: IMMED FLUSH WITH COPIOUS AMOUNTS OF
WATER. CALL MD . INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING
(GIVE O* 2/ARTF RESP). INGEST: GET MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:EXTINGUISHING MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:COLLECT SPILL WITH ABSORBENT MATERIAL AND
PLACE IN SEALED CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED. NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:GENERAL MECHANICAL.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.05
Solubility in Water:SOLUBLE
Appearance and Odor:WHITE LOTION, ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LASER TYPE TONER, EX
CAGE:XASXS
CAGE:XASXS
============= Composition/Information on Ingredients =============
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: <1%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:IRON OXIDE
CAS:1317-61-9
Fraction by Wt: 25-45%
OSHA PEL:10 MG/M3
ACGIH TLV:5 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MINIMAL RESP TRACT IRRIT MAY OCCUR AS
W/EXPOS TO LG AMTS OF ANY NON-TOXIC DUST. IN A CHRONIC INHAL STUDY
IN RATS USING SPEC TONER, THERE WERE NO LUNG CHANGES AT ALL IN
LOWEST LEVEL (1 MG/M3), MOST REL EVANT LEVEL TO POTENTIAL HUMAN
EXPOS. VERY SLIGHT DEGREE OF FIBROSIS WAS NOTED IN 25% OF ANIMALS
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:AT MIDDLE EXPOS LEVEL (4 MG/M3) WHILE
SLIGHT DEGREE OF FIBROSIS WAS OBSERVED AT HIGHEST EXPOS LEVEL (16
MG/M3) IN ALL ANIMALS. THESE FINDINGS ARE ATTRIBUTED TO "LUNG
OVERLOADING", GENERIC RES PONSE TO EXCESS AMTS OF ANY DUST RETAINED
IN LUNGS FOR PRLNGD INTERVAL. SPEC TEST TONER WAS TEN TIMES MORE
(SUPP DATA)
Medical Cond Aggravated by Exposure:NONE WHEN USED AS INTENDED IN THE
PRINTING EQUIPMENT FOR WHICH IT IS DESIGNED.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOSURE. SKIN:WASH WITH SOAP AND WATER.
INGEST:DILUTE STOMACH CONTENTS WITH SEVERAL GLASSES OF WATER.
EYES:FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST 15 MINUTES .
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, DRY CHEMICAL, CO*2, WATER SPRAY OR MIST.
Fire Fighting Procedures:NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:MATERIAL IS COMBUSTIBLE. WHEN DISPERSED
IN AIR IT CAN FORM EXPLOSIVE MIXTURE.
================== Accidental Release Measures ==================
Spill Release Procedures:LOOSE TONER CAN BE REMOVED USING A VACCUM
CLEANER. MAY BE SWEPT UP (AVOID DUST INHALATION. USE APPROPRIATE
DUST MASK IF NECESSARY)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, WELL VENTILATED
AREA. AVOID PROLONGED INHALATION OF EXCESSIVE DUST.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:RESPIRABLE THAN COMMERCIALLY AVAILABLE TONER TO COMPLY
WITH EPA TESTING PROTOCOL.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:>212F,>100C
Spec Gravity:1.5-1.7(H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:FINE BLACK POWDER MILD RESINOUS ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION CAN BE TOXIC
DEPENDING ON CONDITIONS. AVOID BREATHING SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE. INSURE CONFORMITY WITH
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:20-3380-064, EPOMET MOLDING COMPOUND
Preparer's Name:TOM DERAM
CAGE:09410
CAGE:09410
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 60-70%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:FIBROUS GLASS; (FIBERGLASS). PEL AS NUISANCE PARTICULATES.
RTECS #:LK3651000
Fraction by Wt: 2-12%
OSHA PEL:15 MG/M3TDUST;5RDUST
ACGIH TLV:10 MG/M3 DUST
Ingred Name:ANHYDRIDE HARDENERS-PROPRIETARY
Fraction by Wt: 5-10%
ACGIH TLV:0.2 MG/M3 (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:PROLONGED OR REPEATED DUST INHALATION
MAY LEAD TO PULMONARY INVOLVEMENT (PNEUMOCONIOSIS) SUCH AS
SILICOSIS. REPEATED SKIN CONTACT MAY LEAD TO SENSIT (ALLERGIC SKIN
REACTION) IN SOME INDIVIDUALS. PROLO NGED INHALATION OF FUMES FROM
MOLDING OR POST-CURE OPERATIONS CAN CAUSE RESPIRATORY
IRRITATION/DISCOMFORT.
Explanation of Carcinogenicity:SILICA, CRYSTALLINE (QUARTZ): GROUP 2
(NTP), GROUP 2A (IARC).
Effects of Overexposure:EYE: MAY CAUSE IRRIT. ALLERGIC RESPIRATORY
REACTIONS COULD INCLUDE ASTHMA LIKE SYMPTOMS. INHAL: OVEREXPOSURE
TO DUST MAY CAUSE RESPIRATORY EFFECTS. ACUTE SYMPTOMS MAY INCLUDE
IRRITATION AND COUGH.
Medical Cond Aggravated by Exposure:CNDTNS AGGRAVATED BY EXPOSURE TO
THE UNCURED MATERIAL INCLUDE ASTHMA, ACUTE OR CHRONIC RESPIRATORY
DISORDERS, ALLERGIES. SOME PERSONS MAY BECOME SENSIT FROM RPTD
INHAL EXPOSURE TO DUST VAPOR/FUMES.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MIN. CALL
PHYSICIAN. SKIN: WASH WITH SOAP AND WATER. INHAL: REMOVE PERSON TO
FRESH AIR. IF BREATHING IS DIFFICULT, GIVE OXYGEN OR ARTIFICIAL
RESPIRATON. CALL PHYSICIAN. INGEST: GIVE PLENTY OFWATER AND INDUCE
VOMITING. CALL A PHYSICIAN. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSICOUS PERSON.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM, WATER SPRAY.
Fire Fighting Procedures:FIRE FIGHTERS EXPOSED TO SMOKE FUMES OR VAPORS
SHOULD WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROT EQUIP ADEQUATE
TO SHIELD SKIN FROM AIRBORNE CONTAM.
Unusual Fire/Explosion Hazard:AVOID EXPOSURE TO AIRBORNE CONTAMINANTS
(SMOKE, FUMES, ETC).
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUMING RECOMMENDED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP PRODUCT DRY, MOISTURE
CONTAMINATION WILL HAVE AN ADVERSE EFFECT ON PRODUCT QUALITY. STORE
IN A DRY AREA AT 5C (41F) OR BELOW.
Other Precautions:AVOID GROSS SKIN CONTAMINATION. AVOID BREATHING DUST
OR VAPOR. AVOID CONTACT WITH EYES. FOR INDUSTRIAL USE ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION IS INADEQUATE USE A NIOSH/MSHA
APPROVED RESPIRATOR WITH ORGANIC VAPOR CARTRIDGES AND DUST
PREFILTER.
Ventilation:LOC EXHST: FOR DUST CONTROL. VENT OUTSIDE THE WORK AREA.
MECH (GENERAL): TO REMOVE AIRBORNE DUST & VAP FROM (SUPP DATA)
Other Protective Equipment:EYE WASH FACILITY.
Work Hygienic Practices:GOOD PERSONAL HYGIENE TO BE FOLLOWED AT ALL
TIMES. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
VENT: WORK AREA. SPECIAL: KEEP AIRBORNE CONTAMINANTS BELOW TLV. OTHER:
TO REMOVE FUMES/VAPORS EMITTED DURING MOLDING PROCESS.
================== Physical/Chemical Properties ==================
Spec Gravity:1.0
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK, GRANULAR SOLID; FAINT EPOXY ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH ACIDS, BASES, AMINES AND STRONG OXIDIZERS.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:PRODUCTS OF THERMAL DECOMP AND/OR FIRE
CONDITIONS WOULD PROBABLY INCL CO, CO*2, HCL AND TOXIC
PARTICULATES.
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL DISPOSAL IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TEFLON FORTIFIED BICYCLE LUBE 11 OZ
Preparer's Name:HENRY KRAUSE
CAGE:GO514
CAGE:GO514
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL (ETHYL ALCOHOL), TECSOL, ALCOHOL, SYNASOL
CAS:64-17-5
RTECS #:KQ6300000
Other REC Limits:1900 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ingred Name:LUBRICANT ESTER BASE
CAS:27178-16-1
RTECS #:AV1485000
Ingred Name:DIPHENYLAMINE, DIISOBUTYLENE REACTION PRODUCT
CAS:68411-46-1
Ingred Name:1-DECENE HOMOPOLYMER, HYDROGENATED *95-4*
CAS:68037-01-4
Ingred Name:AMINES, C11-14-BRANCHED ALKYL, MONOHEXYL & DIHEXYL
PHOSPHATES
CAS:80939-62-4
Ingred Name:2-PROPENOIC ACID, 2-METHYL-,DODECYL ESTER, POLYMER
W/METHYL, 2-METHYL-2-PROPENOATE AND TETRADECYL
2-METHYL-2-PROPENOATE
CAS:68171-50-6
Ingred Name:ETHYLENE, TETRAFLUORO- POLYMER (POLYTETRAFLUOROETHYLENE),
PTFE, TEFLON
CAS:116-14-3
RTECS #:KX4025000
Ingred Name:CARBON DIOXIDE *96-1*
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: 3%
Other REC Limits:10000 PPM
OSHA PEL:5000 PPM
ACGIH TLV:9000 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: LIQUID IS SLIGHTLY IRRITATING.
INHALATION: >1000 PPM MAY CAUSE DEPRESSION. INGESTION: VOMITUS INTO
LUNGS MAY CAUSE ASPIRATION HAZARD.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DRYING, CRACKING, LIGHT HEADEDNESS,
NAUSEA, UNCONSCIOUSNESS, VOMITING.
Medical Cond Aggravated by Exposure:EXISTING DERMATITIS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER.
INGESTION: DON'T INDUCE VOMITING. INHALATION: REMOVE TO FRESH AIR.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:OC
Flash Point:70F
Lower Limits:2.3
Upper Limits:15
Extinguishing Media:WATER FOG, DRY CHEMICAL, CO2, FOAM.
Fire Fighting Procedures:USE WATER SPRAY TO COOL FIRE. DON'T USE DIRECT
STREAM OF WATER. DON'T ENTER W/O FULL BUNKER GEAR. USE WATER TO
COOL CONTAINERS.
Unusual Fire/Explosion Hazard:FLAMMABLE LIQUID.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: WIPE UP W/ABSORBANT RAGS. DON'T USE
CLAY. PLACE IN CLOSED METAL WASTE CONTAINERS. LARGE: USE
NON-FLAMMABLE ABSORBANT. KEEP FREE FROM FLAME/SPARKS. ELIMINATE
IGNITION SOURCE. DON'T HOSE DOWN THE DRAINS. MOVE CONTAINERS TO
WELL VENTILATED AREA.
======================Handling and Storage ======================
Other Precautions:AVOID EXCESSIVE BREATHING OF VAPORS.
============= Exposure Controls/Personal Protection =============
Ventilation:LOCAL/MECHANICAL EXHAUST
Supplemental Safety and Health
SPILLS CONT'D: RECOVER BY PUMPING (USE AN EXPLOSION PROOF PUMP)
W/SUITABLE ABSORBANT. PERMISSIBLE CONCENTRATION FOR PRODUCT: AIR -
450 PPM FOR 4 HOURS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:250F
Vapor Density:1.8
Spec Gravity:0.82
Evaporation Rate & Reference:(BU AC =1): 0.1
Solubility in Water:>60%
Appearance and Odor:WHITE TRANSLUCENT W/MILD SOLVENT ODOR.
Percent Volatiles by Volume:70
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:HEAT & OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:HEAT/COMBUSTION: CO, CO2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. FLAMMABLE LIQUID UN1255.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CARBON BLACK, N-908 STAINLESS
CAGE:JO712
CAGE:JO712
============= Composition/Information on Ingredients =============
Ingred Name:CARBON BLACK (NON ACTIVATED, MINERAL ORIGIN) (CONTAINING
ING 2)
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 100%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:POLYNUCLEAR AROMATIC HYDROCARBONS (PAH)
Fraction by Wt: <0.1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPP DATA:CAN RSLT IN FIRE/EXPLO. CARBON BLACK MIXED
W/FATTY OILS/SODIUM CAN UNDERGO SPONT HEATING. MAY REACT (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:VIOLENTLY W/NITRIC ACID.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP:STUDY DESIGN & METHODOLOGY, LACK OF APPROP
CONTROLS FOR CIGARETTE SMOKING & OTHER CONFOUNDING (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:FACTORS SUCH AS CONCURRENT EXPOS TO CARBON MONOXIDE,
COAL OIL & PETRO VAPS. MOREOVER, REVIEW OF THESE (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:STUDIES INDICATES THAT WORK ENVIRON CONCS OF CARBON
BLACK WERE CONSIDERABLY GREATER THAN CURRENT OCCUP (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:EXPOS STDS. ANIMAL:IN NON-ADSORBED FORM, SOME
POLYNUCLEAR AROMATIC HYDROCARBONS HAVE BEEN FOUND TO BE (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:CARCINS IN ANIMAL STUDIES. NO CORRELATING CARCIN EFT,
HOWEVER, HAS BEEN OBSERVED IN HUMANS DUE TO EXPOS TO(ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:CARBON BLACK. CHRONIC INFLAMM, LUNG FIBROSIS & LUNG
TUMORS HAVE BEEN OBSERVED IN SOME RATS EXPTLY EXPOS, (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:FOR LONG PERIODS OF TIME, TO EXCESSIVE CONCS OF
CARBON BLACK & SEVERAL OTHER INSOL FINE DUST PARTICLES. (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:MANY RESEARCHERS CONDUCTING RAT INHAL STUDIES
BELIEVE THAT THESE EFTS MOST LIKELY RSLT FROM MASSIVE ACCUM(ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:OF SM DUST PARTICLES IN LUNG WHICH OVERWHELM NATURAL
LUNG CLEARANCE MECHANISMS, KNOWN AS "LUNG OVERLOAD" (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:PHENOMENON, RATHER THAN FROM SPECIFIC CHEMICAL
EFFECT OF DUST PARTICLES IN LUNG.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:INHAL OF ACUTE CONCS MAY
CAUSE TEMPORARY DISCOMFORT TO NOSE & RESP TRACT. INGEST/SKIN:NO
CONSEQUENCES. EYE:MAY CAUSE IRRIT AT HIGH DUST LEVELS. TARGET
ORGANS:LUNGS & RESP SYS. CHRONIC:HUMA N:EPIDEMIOLOGICAL STUDIES OF
WORKERS INCARBON BLACK PRDCG INDUSTRIES OF NORTH AMERICA & WESTERN
EUROPE(EFTS OF OVEREXP)
Explanation of Carcinogenicity:CARBON BLACK:IARC MONOGRAPHS, VOL 65, PG
149, 1996:GROUP 2B.
Effects of Overexposure:HLTH HAZ:SHOW NO EVID OF CLINICALLY
SIGNIFICANT, ADVERSE HLTH EFTS DUE TO OCCUP EXPOS TO CARBON BLACK.
EARLY STUDIES IN FORMER USSR & EASTERN EUROPE RPT RESP DISEASES
AMONG WORKERS EXPOS TO CARBON BLA CK, INCL:BRONCH, PNEUMOCONIOSIS,
EMPHYSEMA & RHINITIS. THESE STUDIES ARE OF QUESTIONABLE VALIDITY,
DUE TO INADEQ (ING 5)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE FROM EXPOSURE.
SKIN:WASH W/SOAP & WATER FOR HYGIENIC PURPOSES. EYES:RINSE W/WATER
FOR AT LEAST 15 MINUTES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER MIST OR NOZZLE JET TO COOL BELOW IGNITION
POINT &/OR EXCLUDE AIR BY PURGING W/CO*2 OR OTHER INERT GAS.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP. BE
AWARE OF POSS ASPHY HAZ. HAVE AIR SUPPLY AVAIL. SODIUM (NA) IONS IN
CARBON BLACK SUPPORT COMBUSTION AT(SUPDAT)
Unusual Fire/Explosion Hazard:FLAMMABILITY:IGNITION IN AIR ABOVE 315C.
HAZARDOUS GASES/VAPORS PRODUCED IN FIRE ARE CARBON MONOXIDE &
CARBON DIOXIDE.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM UP POWDER, OR SPRAY W/WATER FOG & SWEEP
INTO SUITABLE CONTAINER. DO NOT SWEEP DRY TO AVOID TLV. WEAR
APPROPRIATE PROTECTIVE EQUIPMENT FOR DUST LEVELS OBTAINED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CHECK FOR ADEQUATE OXYGEN LEVELS &
ELEVATED LEVELS OF CO BEFORE ENTERING CLOSED VESSELS OR CONFINED
SPACES.
Other Precautions:SHELF LIFE: INDEFINITE IF STORED UNDER COVER IN
ORIGINAL PACKAGING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED DUST MASK FOR EXTENDED EXPOS;
NIOSH APPRVD DUST PROT RESP WHEN CARBON BLACK DUST EXCEEDS LIMIT OF
3.5 MG/M3 TO 17.5 MG/M3; NIOSH APPRVD FULL FACE/POWERED AIR
RESP/SUPPLIED AIR/SCBA WHEN LEVELS EXCEED 17 MG/M3.
Ventilation:SUFFICIENT VENTILATION, IN VOLUME & PATTERN, TO MAINTAIN
EXPOSURE LEVELS BELOW TLV.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . PROTECTIVE CLOTHING OR FOOTWEAR ARE NOT
REQD.
Work Hygienic Practices:WASH EXPOSED SKIN DAILY W/MILD SOAP/DETERGENT.
WASH EXPOSED CLOTHING DAILY.
Supplemental Safety and Health
FIRE FIGHT PROC:EXTREME SLOW RATE, FIRES PERSIST ONLY W/DULL RED GLOW
UNDER SURF. DUE TO THERMAL INSULATION PROPERTIES OF CARBON, FIRES
MAY CONTINUE UNDETECTED FOR EXTENDED PERIODS OF TIME. AVOID APPL
YING DIRECT FLAME/SPKS INTO CARBON BLACK. MATLS TO
AVOID:W/OXIDIZING AGENT (I.E., CHLORATES, BROMATES & NITRATES)(ING
3)
================== Physical/Chemical Properties ==================
Spec Gravity:1.7-1.9
Solubility in Water:INSOLUBLE
Appearance and Odor:SOLID, DARK GREY PELLETS OR POWDER; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPAT W/STRONG OXIDIZERS. CARBON BLACK CAN REACT W/OXIDIZING AGENTS.
FINELY DIVIDED CARBON INTIMATELY MIXED (SUPDAT)
Stability Condition to Avoid:PRODUCT IS STABLE UNDER NORMAL CONDITIONS.
CARBON BLACK CAN IGNITE WHEN EXPOSED TO EXCESSIVE HEAT.
Hazardous Decomposition Products:HAZARDOUS DECOMPOSITION PRODUCTS ARE
CARBON MONOXIDE & CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W ALL FEDERAL, PROVINCIAL STATE &
LOCAL REGULATIONS. SPILLED CARBON BLACK IS NOT CLASSIFIED AS
HAZARDOUS WASTE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:8700/9700 DRY INK-TYPE 19 TONER
CAGE:FO160
CAGE:34936
CAGE:FO160
============= Composition/Information on Ingredients =============
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 10%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192
Ingred Name:STYRENE ACRYLIC RESIN
Fraction by Wt: 90%
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
Effects of Overexposure:IRRITATION OF EYES OR NOSE.
======================= First Aid Measures =======================
First Aid:SKIN & EYES: REMOVE FROM AREA OF IRRITATION. FLUSH EYES TO
REMOVE DUST PARTICLES. DON'T INGEST.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM IS RECOMMENDED
Fire Fighting Procedures:AVOID BREATHING SMOKE & CLOUDS OF AIRBORNE
DUST WHICH BURN.
Unusual Fire/Explosion Hazard:SEVERE DUSTING MAY CAUSE EXPLOSION HAZARD
IF EXPOSED TO SPARKS OR FLAMES.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM CLEAN, BRUSH INTO DUST PAN OR WIPE WITH
CLOTH. AVOID SPARKS AND OPEN FLAMES.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FORM SPARKS, OPEN FLAMES,
OXIDIZERS AND CORROSIVES. AVOID BREATHING SMOKE IF BURNINGAVOID
CREATING DUST
Other Precautions:STORE IN COOL, DRY PLACE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:LOCAL EXHAUST
Other Protective Equipment:AS REQUIRED BY YOUR COMPANY.
Supplemental Safety and Health
MSDS DATE: 12/84.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.1
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK POWDER, FAINT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CORROSIVES AND OXIDIZERS
Stability Condition to Avoid:SPARKS AND OPEN FLAMES.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN SANITARY LANDFILL IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS AND ORDINANCES.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:471263 GAS AMPOULE ASSEMBLY
CAGE:FO723
CAGE:FO723
CAGE:55799
============= Composition/Information on Ingredients =============
Ingred Name:NITROGEN
CAS:7727-37-9
RTECS #:QW9700000
Fraction by Wt: 5.0%
ACGIH TLV:ASPHYXIANT; 9192
Ingred Name:HYDROGEN CYANIDE (SARA III)
CAS:74-90-8
RTECS #:MW6825000
Other REC Limits:10 PPM
OSHA PEL:S, 10 PPM STEL
ACGIH TLV:S, C 10 PPM; 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RATS LD50 = 120 MG/CUM
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: UTILIZATION OF DELIVERED
OXYGEN, RESULTING IN RAPID CELLULAR ASPHYXIATION, WEAKNESS,
CONFUSION, HEADACHE, NAUSEA, COLLAPSE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:ANTIDOTE KITS FOR USE BY MEDICAL PERSONNEL ARE
AVAILABLE FROM THE ELI LILLY COMPANY AS CYANIDE ANTIDOTE PACKAGE
M-76. IF PHYSICIANS, REGISTERED NURSES, OR TRAINED EMERGENCY
MEDICAL TECHNICIANS ARE REA DILY AVAILABLE & CLOSE BY THE SCENE,
CONTENTS OF SUCH A KIT CAN BE CRUCIAL FOR THE APPROPRIATE SPECIFIC
TREATMENT.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE THE VICTIM FROM EXPOSURE. APPLY ARTIFICIAL
RESPIRATION IF THE VICTIM ISN'T BREATHING. DON'T USE MOUTH-TO-MOUTH
RESUSCITATION. THIS INTERRUPTED APPLICATION OF AMYL NITRITE IS
IMPORTA NT AS CONTINUOUS APPLICATION MAY PREVENT ADEQUATE
OXYGENATION. REPEAT APPLICATION 5 TIMES AT 15 SECOND INTERVALS. USE
A FRESH PEARL EVERY 5 MINS UNTIL 3 OR FOUR PEARLS HAVE BEEN USED.
===================== Fire Fighting Measures =====================
Extinguishing Media:THIS GAS MIXTURE ISN'T FLAMMABLE. USE MEDIA
APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:USE STANDARD FIRE FIGHTING EQUIPMENT INCLUDING
SELF-CONTAINED PRESSURE DEMAND BREATHING APPARATUS W/FULL
FACEPIECE.
Unusual Fire/Explosion Hazard:GLASS AMPOULES MAY RUPTURE IN FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. AVOID BREATHING GAS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE PROTECTED
FROM PASSING OR FALLING OBJECTS & FROM CRUSHING FORCES.
Other Precautions:AVOID BREATHING GAS. AVOID CONTACT W/SKIN. USE IN
EXPOSURE WHILE CRUSHING AMPOULES IN HOOD.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DUE TO THE LIMITED AMOUNT OF HYDROGEN CYANIDE IN
AN AMPOULE & THE LOW RELEASE RATE EMPLOYED IN INSTRUMENT
CALIBRATION, RESPIRATORY PROTECTION ISN'T INDICATED UNDER
CONDITIONS OF INTENDED USE.
Ventilation:CRUSH AMPOULES INDIVIDUALLY IN AN EXHAUST HOOD EQUIPPED TO
ASPIRATE AIR AT A FACE VELOCITY OF 100FT/MIN OR GREATER.
Supplemental Safety and Health
AMPLOULES ARE FOR USE W/471747 CALIBRATION CHECK KIT. USING THIS KIT,
CONTENTS OF ONE AMPOULE ARE COMBINED W/5 LITERS OF AIR TO PRODUCE A
10 PPM IN AIR GAS MIXTURE FOR HCN INSTRUMENT CALIBRATION. GAS AT
ATMOSPHERIC PRESSURE AT 70F. EACH AMPOULE CONTAINS 1 MG/CUM OF 5%
HCN IN N2 GAS MIXTURE, 0.05 MILLIGRAMSN HCN.
================== Physical/Chemical Properties ==================
Vapor Density:<1
Solubility in Water:VERY SOLUBLE
Appearance and Odor:COLORLESS GAS, VARIOUSLY DESCRIBED AS BITTER
ALMOND, ONIONY, GARLICKY ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:CAUSTICS, AMINES, OXIDIZERS, PEROXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:IF SURPLUS AMPOULES MUST BE DISPOSED, CRUSH
AMPOULES INDIVIDUALLY IN AN EXHAUST HOOD EQUIPPED TO ASPIRATE AIR
AT A FACE VELOCITY OF 100 FT/MIN OR GREATER. LEAVE CRUSHED AMPOULES
IN HOOD FOR AT LEAST 1 HOUR BEFORE REMOVING/DISCARDING TO TRASH.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ALPH-D-GLUCOSE, A.C.S. REAGENT 25307-3
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:D-GLUCOSE
CAS:50-99-7
RTECS #:LZ6600000
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL, RAT)25800 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:MAY BE HARMFUL BY INHALATION,
INGESTION OR SKIN ABSORPTION. MAY CAUSE IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:IMMEDIATELY FLUSH W/COPIOUS AMTS OF WATER FOR AT LEAST
15 MINUTES. SKIN:IMMEDIATELY WASH W/SOAP & COPIOUS AMTS OF WATER.
WASH CONTAMINATED CLOTHING BEFORE REUSE. INHAL:REMOVE TO FRESH AIR.
SUPPOR T BREATHING (GIVE O2/ARTIFICIAL RESPIRATION). CALL MD.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL POWDER,
ALCOHOL OR POLYMER FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT TO PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP, PLACE IN BAG AND HOLD FOR WASTE
DISPOSAL. AVOID RAISING DUST. VENTILATE AREA AND WASH SPILL SITE
MASK AND PROTECTIVE CLOTHING .
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE. KEEP TIGHTLY
CLOSED.
Other Precautions:DO NOT BREATHE DUST. DO NOT GET IN EYES, ON SKIN OR
CLOTHING. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR IN NON-VENTILATED
AREAS.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER USE AND BEFORE
EATING, DRINKING, SMOKING OR USING SANITARY FACILITIES .
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:307F,153C
Appearance and Odor:WHITE POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF CARBON MONOXIDE, CARBON
DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE IN WATER & DILUTE TO 5% SOLN. CHECK PH
& ADJUST TO 7 IF NECESSRY. POUR SOLN DOWN DRAIN W/RUNNING WATER &
CONTINUE TO FLUSH DRAIN SYS FOR 10 MIN. IF UNABLE TO FLUSH SOLN
DOWN DRAIN, DISPOSE I/ A/W FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EN LUST QD STY ALKYD YELLOW 33538 ID 743310
CAGE:61196
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 5%
Other REC Limits:LFL 1.7/UFL 7.1
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: < 5%
Other REC Limits:LFL 1.7/UFL 7.6
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VM&P NAPHTHA (VAPOR PRESSURE 40 MM HG)
CAS:8030-30-6
RTECS #:DE3030000
Fraction by Wt: 30%
Other REC Limits:LFL 1.0/UFL 6.0
OSHA PEL:300 PPM;400 PPM STEL
ACGIH TLV:300 PPM; 1350 MG/M3
Ingred Name:ISOBUTYL ALCOHOL (VAPOR PRESSURE 10 MM HG)
CAS:78-83-1
RTECS #:NS1752000
Fraction by Wt: 5%
Other REC Limits:LFL 1.0/UFL 11.0
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: < 1%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE
CAS:14464-46-1
RTECS #:VV7325000
Fraction by Wt: 5%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.05 MG/M3 RDUST9293
Ingred Name:LEAD CHROMATE (SARA 313)
CAS:7758-97-6
RTECS #:GB2975000
Fraction by Wt: 20%
OSHA PEL:0.05 MG/M3;0.10 CEIL
ACGIH TLV:0.05 MG/M3
Ingred Name:TALC (CONTAINING NO ASBESTOS)
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 10%
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST; 9192
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: < 1%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:SILICA, AMORPHOUS, DIATOMACEOUS EARTH, CONTAINING LESS THAN
1% CRYSTALLINE SILICA
CAS:61790-53-2
RTECS #:HL8600000
Fraction by Wt: < 5%
OSHA PEL:20 MPPCF
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:VOC 4.32 LB/GAL LESS WATER & NPRS* 518 B/L LESS WATER
CALCULATED
RTECS #:9999999VO
Ingred Name:VOC 12.51 LB/GAL SOLIDS 1501 G/L SOLIDS CALCULATED
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:GASTROINTESTINAL/EYE/NOSE/THROAT
IRRIT. ASPIRATION INTO LUNG/CAUSE CHEMICAL PNEUMONITIS/POSS FATAL.
INHALE: ACUTE CTRL NERV SYST DEPRESS. SKIN IRRIT, DEFATTING. LIVER,
PERM BRAIN/NERV SYST DAMAGE; SEV ERE DAMAGE TO BLOOD FORMING,
URINARY, REPRODUCTIVE SYST. LUNG CANCER. CRYSTALLINE
SILICA/PNEUMOCONIOSIS, LUNG DISEASE.
Explanation of Carcinogenicity:CHROMIUM/CERTAIN CHROMIUM
COMPOUNDS/POTENTIAL CARCINOGENS/NTP. CRYSTALLINE SILICA/LIMITED
CARCINOGENICITY EVIDENCE/IARC.
Effects of Overexposure:SWALLOWING: NAUSEA, VOMITING. INHALATION:
HEADACHE, DIZZINESS, NAUSEA, CONFUSION. LOSS OF APPETITE, METALLIC
TASTE IN MOUTH, ANXIETY, CONSTIPATION, NAUSEA, WEAKNESS, INSOMNIA,
MUSCLE/JOINT PAIN, FINE TREMORS, NUMBNESS, DIZZINESS,
HYPERACTIVITY, COLIC. PURPOSELY INHALING CONTENTS CAN BE
HARMFUL/FATAL
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY CONDITIONS
AGGRAVATED BY EXPOSURE TO CRYSTALLINE SILICA. PRE-EXISTING KIDNEY
CONDITIONS AGGRAVATED BY EXPOSURE TO LEAD. TOLUENE CAUSES KIDNEY,
LUNG, SPLEEN DAMAGE/LAB ANIMALS.
======================= First Aid Measures =======================
First Aid:SWALLOW: DO NOT INDUCE VOMIT. CALL POISON CONTROL CENTER,
HOSPITAL EMERGENCY ROOM, PHYSICIAN. INHALE: REMOVE TO FRESH AIR.
BREATHING STOPPED, GIVE CPR. KEEP WARM/QUIET. GET MEDICAL
ATTENTION. EYE: FLU SH W/LARGE AMOUNT WATER, LIFT UPPER/LOWER LIDS
OCCASIONALLY-15 MIN. GET MEDICAL ATTENTION. SKIN: REMOVE
CONTAMINATED CLOTHING. WASH AFFECTED AREA W/SOAP & WATER. IRRIT
PERSISTS/GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:20.0F,-6.7C
Lower Limits:1.0
Upper Limits:11.0
Extinguishing Media:CARBON DIOXIDE, ALL PURPOSE DRY CHEMICAL OR ALCOHOL
FOAM. POLYMER FOAM IS PREFERRED FOR LARGE FIRES.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE, MAY BE USED TO COOL
EXPOSED CONTAINERS TO PREVENT PRESS BUILD-UP, AUTO-IGNITION,
EXPLOSION W/HEAT. WATER USED/FOG NOZZLES PREFERRED.
Unusual Fire/Explosion Hazard:DURING EMERGENCY CONDITIONS, OVEREXPOSURE
TO DECOMPOSITION PRODUCTS MAY CAUSE A HEALTH HAZARD. SYMPTOMS MAY
NOT BE IMMEDIATELY APPARENT. GET MEDICAL ATTENTION.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP SPECTATORS AWAY. REMOVE IGNITE SOURCES.
DIKE/CONTAIN SPILL W/INERT MATERIAL. TRANSFER LIQUIDS TO COVERED
METAL CONTAINERS FOR RECOVERY/DISPOSAL OR REMOVE W/INERT ABSORB.
USE NON-SPARK TOOLS. PREV ENT CONTAM OF SEWERS, STREAMS,
GROUNDWATER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 100 F (38 C). STORE
LARGE QUANTITIES IN COMPLIANCE WITH OSHA 29CFR1910.106. DO NOT TAKE
INTERNALLY. CLOSE AFTER EACH USE.
Other Precautions:DO NOT BREATHE SANDING DUST. DO NOT WASH AND REUSE
EMPTY CONTAINERS. GROUND/BOND CONTAINERS TO THE RECEIVING
CONTAINER. DO NOT WELD, BRAZE OR CUT EMPTY CONTAINER. NEVER USE
PRESSURE TO EMPTY. DRUM ISNOT PRESSURE VESSEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MAY NOT REQUIRE RESPIRATORY PROTECTION IF USED
IN WELL VENT AREAS. RESTRICTED VENT USE NIOSH APPROVED CHEM
CARTRIDGE RESPIRATOR. MAY ALSO NEED A MECHANICAL PREFILTER. IN
CONFINED AREAS USE A NIOSH/MSH A APPROVED AIR SUPPLIED RESPIRATOR.
Ventilation:PROVIDE GENERAL DILUTION/LOCAL EXHAUST VENT IN SUFFICIENT
VOLUME/PATTERN/KEEP CONC HZDS INGRED BELOW LOWEST EXPOS LIMIT.
Other Protective Equipment:AS REQUIRED TO PREVENT SKIN CONTACT. SEE
OSHA STANDARD FOR LEAD.
Work Hygienic Practices:WASH HANDS AND FACE THOROUGHLY BEFORE EATING OR
DRINKING.
Supplemental Safety and Health
FLAMMABLE. METAL OXIDE OVEREXPOSURE MAY RESULT IN "METAL FUME
FEVER"-FEVER, CHILLS, AND COUGH. AN AIR PURIFYING OR SUPPLIED AIR
RESPIRATOR MAY BE REQUIRED DEPENDING UPON LEVELS OF EXPOSURE.
REMOVE DEC OMP PROD GENERATED WHEN WELDING, CUTTING, BRAZING
OBJECTS COATED W/PROD. LEAD CHROMATE/POTENTIAL ANIMAL
CARCINOGEN/IARC.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:203 TO 300F
Vapor Density:> THAN AIR
Spec Gravity:1.2
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Appearance and Odor:PAINT
Percent Volatiles by Volume:65
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS. OXIDIZING MATERIALS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT (>100 F (38 C) AND
SOURCES OF IGNITION.
Hazardous Decomposition Products:MAY PRODUCE SMOKE, CARBON MONOXIDE,
CARBON DIOXIDE, METAL OXIDES. OXIDES OF LEAD AND CHROMIUM MAY BE
GENERATED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE PER FED, STATE, LOCAL LAWS/REGULATIONS
FOR TOXIC/IGNITABLE WASTE D008/D001. INCINERATE ONLY IN EPA
PERMITTED FACILITY. DO NOT INCINERATE CLOSED CONTAINER. DISPOSE
ABSORBENT DIKING MATERIALS IN COVERED METAL CONTAINERS IN HZDS
WASTELANDFILL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:R-0010 CALCIUM BUFFER
Preparer's Name:STEPHEN M. BACON
CAGE:89975
CAGE:89975
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 1.9%
Other REC Limits:2MG/M3 CEILING NIOSH
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RATS LD50: 140-340 MG/KG
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION, DERMATITIS, & BURNS.
EYES: DESTRUCTION OF TISSUE, IRREPARABLE CORNEAL DAMAGE & POSSIBLE
BLINDNESS. INGESTION: GASTROINTESTINAL IRRITATION & BURNS OF THE
MOUTH, THROAT, EPOPHAGUS, & S TOMACH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: IRRITATION, DERMATITIS, & BURNS. EYES:
DESTRUCTION OF TISSUE, IRREPARABLE CORNEAL DAMAGE & POSSIBLE
BLINDNESS. INGESTION: GASTROINTESTINAL IRRITATION & BURNS OF THE
MOUTH, THROAT, ESOPHAGUS, & S TOMACH.
======================= First Aid Measures =======================
First Aid:SKIN/EYES: FLUSH W/COPIOUS AMOUNTS OF WATER FOR 15 MINS. WASH
AREA THOROUGHLY W/SOAP & WATER. INGESTION: DON'T INDUCE VOMITING.IF
CONSCIOUS, GIVE LARGE QUANTITIES OF WATER. IF VOMITING OCCURS
SPONTANE OUSLY, KEEP AIRWAY CLEAR. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS REQUIRED.
================== Accidental Release Measures ==================
Spill Release Procedures:NEUTRALIZE W/WEAK ACID SUCH AS ACETIC ACID &
FLUSH TO SEWER OR, IF DESIRED, ABSORB NEUTRALIZED SOLUTION
W/VERMICULITE, OR OTHER INERT MAERIAL, & CONTAINERIZE FOR OTHER
DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID ALL CONTACT WITH SKIN, CLOTHING
OR OTHER CHEMICALS, METALS.
Other Precautions:CAN REACT VIOLENTLY WITH ACIDS; GENERATES HEAT ON
DILUTION. SHOULD ALWAYS BE HANDLED WITH CAUTION.
============= Exposure Controls/Personal Protection =============
Other Protective Equipment:LAB COAT
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:230F
Vapor Pres:17
Vapor Density:0.6
Spec Gravity:1.2
Evaporation Rate & Reference:(WATER = 1): 1
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS, ODORLESS LIQUID
Percent Volatiles by Volume:80%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
METALS SUCH AS ALUMINUM, OTHER CHEMICALS, METALS, STRONG ACIDS,
ALDEHYDES, COMPOUNDS, ORGANIC HALOGENS, TIN, LEAD/ZINC.
Hazardous Decomposition Products:FLAMMABLE HYDROGEN GAS
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH NEUTRALIZED SOLUTION TO SEWER. IF ABSORBED
W/INERT MATERIAL, DISPOSE OF BY INCINERATION OR OTHER METHOD
APPROVED OF BY LOCAL, STATE, OR FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SA 824 5292
CAGE:EO761
CAGE:70878
CAGE:EO761
============= Composition/Information on Ingredients =============
Ingred Name:BARIUM SULFONATE
CAS:25619-56-1
RTECS #:CR0700000
OSHA PEL:0.5 MG/M3 (BA)
ACGIH TLV:0.5 MG/M3 (BA); 8990
===================== Hazards Identification =====================
Effects of Overexposure:MAY CAUSE SKIN & EYE IRRITATION WITH PROLONGED
CONTACT.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. CALL A PHYSICIAN IMMEDIATELY. SKIN CONTACT: WASH
THOROUGHLY WITH SOAP AND WATER. SWALLOWED: CALL A PHYSICIAN
IMMEDIATELY. INDUCE VOMITI NG IF VICTIM IS CONSCIOUS.
===================== Fire Fighting Measures =====================
Flash Point:>284F C.O.C.
Extinguishing Media:DRY CHEMICAL, CO2, WATERFOG, SAND, FOAM
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR AN APPROVED SCBA.
Unusual Fire/Explosion Hazard:DENSE SMOKE.
================== Accidental Release Measures ==================
Spill Release Procedures:TRANSER BULK OF MATERIAL INTO ANOTHER
CONTAINER. ABSORB REMAINING RESIDUE WITH PROPEABSORBENTS SUCH AS
SAND, EARTH, VERMICULITE. SWEEP UP AND DISPOSE AS SOL WASTE IN
ACCORDANCE TO LOCAL, STATE AND FED ERAL REGULATIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED. AVOID CONTACT
W/SKIN/EYES/CLOTHING. WASH AFTER HANDLING. WASH CLOTHINGEFORE
REUSE. KEEP AWAY FROM FEED AND FOOD PRODUCTS
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Ventilation:NONE REQUIRED
Other Protective Equipment:NONE REQUIRED
Supplemental Safety and Health
MSDS DATED: 12 NOV 1985.
================== Physical/Chemical Properties ==================
Spec Gravity:0.947
Solubility in Water:NEGLIGIBLE
Appearance and Odor:SEMI-SOLID, GREEN, GREASE, MINERAL OIL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGTS/HYDROGEN PEROXIDE/CHROMIC ACID/BROMINE
Hazardous Decomposition Products:CO AND CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:BY METHODS CONSISTENT WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CRONAWELD 377
Preparer's Name:HUGH KELLY
CAGE:67292
CAGE:67292
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM METASILICATE; SODIUM SILICATE; WATER GLASS; DISODIUM
SALT SILIC ACID
CAS:6834-92-0
RTECS #:VV9275000
Fraction by Wt: 1-10%
ACGIH TLV:10 MG/CUM
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: 31-60%
OSHA PEL:5 MG/CUM
Ingred Name:MANGANESE, MN COMPOUNDS
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 1-10%
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:CHROMIUM METAL, CHROMIUM, CHROME (SUSPECTED A1 HUMAN
CARCINOGEN BY IARC, NTP & ACGIH)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 11-30%
OSHA PEL:1 MG/CUM (CEILING)
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:NICKEL (SOLUBLE) (SUSPECTED HUMAN CARCINOGEN BY NTP, IARC,
ACGIH) INTENDED CHANGE (IC)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 11-30%
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/CUM
ACGIH TLV:0.05 MG/CUM IC
Ingred Name:TITANIUM DIOXIDE, TIO2
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 1-10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:FLUORSPAR *93-1*
CAS:14542-23-5
Fraction by Wt: 1-10%
ACGIH TLV:2.5 MG/CUM
Ingred Name:CALCIUM CARBONATE, DOMOLITE, LIMESTONE, WHITING
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 1-10%
OSHA PEL:15 MG/CUM (DUST)
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:CLAY (KAOLIN)
CAS:1332-58-7
RTECS #:GF1670500
Fraction by Wt: 1-10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INHALATION: DISCOMFORT, SIDEROSIS
(IRON DEPOSITS IN THE LUNGS), EFFECTS TO PULMONARY FUNCTION. ARC
RAYS CAN INJURE EYES & BURN SKIN. ELECTRIC SHOCK CAN KILL.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:INHALATION: DIZZINESS, NAUSEA, & DRYNESS OR
IRRITATION TO NOSE, THROAT, OR EYES.
Medical Cond Aggravated by Exposure:RESPIRATORY OR ALLERGIC CONDITIONS
======================= First Aid Measures =======================
First Aid:CALL FOR MEDICAL AID. EMPLOY FIRST AID TECHNIQUES RECOMMENDED
BY THE AMERICAN RED CROSS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
======================Handling and Storage ======================
Handling and Storage Precautions:READ/UNDERSTAND MANUFACTURER'S
INSTRUCTIONS & THE PRECAUTIONARY LABEL ON THIS PRODUCT. WELDING
ARCS/SPARKS CAN IGNITE COMBUSTIBLES.
Other Precautions:TRAIN THE WELDER NOT TO TOUCH LIVE ELECTRICAL PARTS &
TO INSULATE HIMSELF FROM WORK & GROUND. AS A RULE OF THUMB, START
W/SHADE WHICH IS TOO DARK TO SEE THE WELD ZONE. THEN GO TO THE NEXT
LIGHTER SHAD E WHICH GIVES SUFFICIENT VIEW OF ZONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRABLE FUME RESPIRATOR OR AIR SUPPLIED
RESPIRATOR WHEN WELDING IN CONFINED SPACE OR WHERE LOCAL EXHAUST OR
VENTILATION DOESN'T KEEP EXPOSURE BELOW TLV.
Ventilation:USE ENOUGH VENTILATION, LOCAL EXHAUST AT ARC, OR BOTH, TO
KEEP THE FUMES/GASES BELOW THE TLV IN BREATHING ZONE.
Other Protective Equipment:PROTECTIVE SCREEN/ARM
PROTECTORS/APRONS/HATS/SHOULDER PROTECTION/DARK SUBSTANTIAL
CLOTHING
Supplemental Safety and Health
MONITOR FUMES FOR ELEMENTS WHEN INDICATED. TRAIN THE WELDER TO KEEP HIS
HEAD OUT OF THE FUMES. THE COMPOSITION AND QUANTITY OF WELDING
FUMES DEPENDS UPON THE METAL BEING WELDED, THE PROCESS, PROCEDURE
S, ELECTRODES USED, COATINGS ON THE METAL, AS WELL AS THE PRESENCE
OF CONTAMINANTS IN THE ATMOSPHERE.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
COMBUSTIBLES
Hazardous Decomposition Products:FLUORIDES/COMPLEX OXIDES OF
METALS/CO/CO2, OZONE & NITROGEN OXIDES FORMED BY RADIATION FROM THE
ARC
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSABLE CONTAINER, OR
LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER, IN FULL COMPLIANCE
W/FEDERAL, STATE, & L OCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NI-167 (PRODUCT CODE 036087-BK)
Preparer's Name:DELMAR BEIGHT
CAGE:0FGH2
CAGE:0FGH2
Contract Num:SP0490-95-D-4037
CAGE:0VYG8
============= Composition/Information on Ingredients =============
Ingred Name:NICKEL
CAS:7440-02-0
RTECS #:QR5950000
Minumum % Wt:50.
Maxumum % Wt:75.
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:CHROMIUM
CAS:7440-47-3
RTECS #:GB4200000
Minumum % Wt:5.
Maxumum % Wt:20.
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Minumum % Wt:1.
Maxumum % Wt:5.
Ingred Name:NICKEL BORON
CAS:11099-25-5
Minumum % Wt:5.
Maxumum % Wt:20.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:SKIN CONTACT MAY CAUSE ALLERGIC
DERMATITIS. EYES: MAY CAUSE IRRITATION. REPEATED OVEREXPOSURE: MAY
CAUSE SENSITIZATION IN SUSCEPTIBLE INDIVIDUALS. CHRONIC EXPOSURE TO
THE EYE CAN CAUSE CORNEAL DAMAGE , POLYCYTHEMIA, HYPERPLASIA OF THE
THYROID GLAND, & DAMAGE TO THE ALPHA CELLS OF THE PANCREAS.
REPEATED INHALATION MAY CAUSE EMPHYSEMA OR PULMONARY FIBROTIC
DISEASE. CHRONIC SKIN CONTACT MAY SPREAD TO THE WHOLE BODY WITH
LESIONS, ITCHING, SORENESS, BURNING SENSATION & REDNESS. MAY ALSO
CAUSE INTERSTITIAL PNEUMONITIS & SENSITIZATION OF THE RESPIRATORY
TRACT IN SUSCEPTIBLE INDIVIDUALS.
Explanation of Carcinogenicity:NICKEL IS LISTED AS A PROBABLE HUMAN
CARCINOGEN. CHROMIUM IS LISTED AS A HUMAN CARCINOGEN. NICKEL &
CHROMIUM HAVE BEEN DETERMINED TO CAUSE CANCER IN EXPERIMENTAL
ANIMALS (IARC, NTP).
Effects of Overexposure:SKIN-MAY CAUSE ALLERGIC DERMATITIS, WITH
REDNESS & PAPULAR FORMATION IN SUSCEPTIBLE INDIVIDUALS, WHICH
USUALLY OCCURS IN THE FOLDS OF THE SKIN. MAY CAUSE ULCERS
PROGRESSING TO DRY & SCALY SKIN, FEVER . EYE-MAY CAUSE IRRITATION,
EXPERIENCED AS REDNESS & EXCESS REDNESS OF THE CONJUNCTIVA.
SWALLOWING-MAY CAUSE NAUSEA, ABDOMIAL PAIN, VOMITING, DIARRHEA, CNS
DEPRESSION, & BURNING SENSATION. INHALATION- MAY CAUSE RESPIRATORY
TRACT IRRITATION, WITH CHEST PAIN, VOMITING, DIARRHEA, BURNING
SENSATION, & CNS DEPRESSION.
Medical Cond Aggravated by Exposure:BREATHING OF DUST MAY AGGRAVATE
ASTHMA AND INFLAMMATORY OR FIBROTIC PULMONARY DISEASE. MAY ALSO
AGGRAVATE AN EXISTING DERMATITIS.
======================= First Aid Measures =======================
First Aid:SWALLOWING-GIVE AT LEAST 2 GLASSES OF MILK OR WATER. INDUCE
VOMITING, UNLESS PATIENT IS UNCONSCIOUS. CALL A PHYSICIAN.
SKIN-WASH THOROUGHLY WITH SOAP AND WATER. INHALATION-REMOVE TO
FRESH AIR. GIVE AR TIFICIAL RESPIRATION IF NOT BREATHING. OXYGEN
MAY BE GIVEN IF NECESSARY. CALL A PHYSICIAN. EYES-FLUSH THOROUGHLY
WITH PLENTY OF WATER. IF DISCOMFORT PERSISTS, SEEK MEDICAL
ATTENTION, PREFERABLY AN OPT HALMOLOGIST.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:USE SPECIAL DRY POWDER METAL EXTINGUISHING MATERIAL
TO EXTINGUISH METAL FIRES. USE APPROPRIATE EXTINGUISHER TO
EXTINGUISH COMBUSTABLE MATERIALS THAT MAY BE IGNITED BY THERMAL
FLAME.
Fire Fighting Procedures:CONSULT AND COMPLY WITH ANSI Z49.1 SAFETY IN
WELDING AND CUTTING, NFPA51B STANDARD FOR FIRE PREVENTION IN USE OF
CUTTING AND WELDING PROCESSES. NFPA51 OXYGEN-FUEL GAS SYSTEMS FOR
WELDING AND CUTTING, AND NFPA58 STANDARD FOR THE STORAGE AND
HANDLING OF LIQUIFIED PETROLEUM GASES.
Unusual Fire/Explosion Hazard:AIRBORNE DUST PARTICLES, ESPECIALLY METAL
DUST, AND ACCUMULATION OF SUCH SHOULD BE TREATED AS EXPLOSIVES. TO
MINIMIZE DANGER FROM DUST EXPLOSIONS, ADEQUATE VENTILATION SHOULD
BE PROVIDED TO SPRAY BOOT H IN ACCORDANCE WITH AMERICAN WELDING
SOCIETY PUBLICATION AWSC2.1-73, AND ACGIH PUBLICATION "INDUSTRIAL
VENTILATION".
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT TO PROTECT AGAINST
HAZARDS AND DISPOSE OF PER WASTE DISPOSAL METHOD.
======================Handling and Storage ======================
Other Precautions:CAUTION: WHEN THERMAL SPRAYING - ELECTRICITY CAN
CAUSE FATAL SHOCK! DO NOT TOUCH LIVE ELECTRICAL PARTS! ARC RAYS CAN
BURN EYES AND SKIN! WEAR RECOMMENDED EYE AND BODY PROTECTION.
FUMES, GAS, & DUST CA N HARM YOUR HEALTH. PROVIDE ENOUGH
VENTILATION AND WEAR RESPIRATORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DEPENDS UPON SPECIFIC USE, CONDITION, AND
LOCATION. IF THERE IS DUSTINESS, WEAR RESPIRATOR SELECTED PER OSHA
1910.134, AND OSHA 29 CFR 1910.252 AND ANSI Z49.1
Ventilation:LOCAL DUST PICK UP AND VENTILATION RECOMMENDED.
Other Protective Equipment:SEE ANSI Z49.1, ANSI Z87.1, ANSI Z88.2 FOR
Supplemental Safety and Health
CAUTION: WHEN THERMAL SPRAYING-ELECTRICITY CAN CAUSE FATAL SHOCK! DO
NOT TOUCH LIVE ELECTRICAL PARTS! ARC RAYS CAN BURN EYES AND SKIN!
WEAR RECOMMENDED EYE ANDBODY PROTECTION. FUMES, GAS, AND DUST CAN
HARM YOUR HEALTH. PROVIDE ENOUGH VENTILATION AND WEAR
RESPIRATORS.(OTHER INFO)
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NONE
Vapor Density:N/VOLATILE
Appearance and Odor:DUSTY GRAY-YELLOWPOWDER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
Hazardous Decomposition Products:WHEN THERMAL SPRAYING, DECOMPOSITION
PRODUCTS WILL VARY WITH OPERATING CONDITIONS. DECOMPOSITION
PRODUCTS OF NORMAL OPERATION FROM THIS THERMAL SPRAY POWDER
(OXIDES, SUB-OXIDES, ETC)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE PERS LOCAL, STATE, AND FEDERAL
REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:PROPER SHIPPING NAME: METAL ALLOY POWDER NOI ITEM
136500 SUB 1.
===================== Regulatory Information =====================
SARA Title III Information:7440-02-0, NICKEL, <75 PERCENT BY WEIGHT .
7440-47-3, CHROMIUM, <20 PERCENT BY WEIGHT. 11099-25-5, NICKEL
BORON, <20 PERCENT BY WEIGHT.
Federal Regulatory Information:ALL INGREDIENTS IN THIS PRODUCT ARE
LISTED IN THE T.S.C.A. INVENTORY.
State Regulatory Information:PROP 65 (CARCINOGEN): WARNING: THIS
PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO
CAUSE CANCER. CAS #7440-02-0, NICKEL; CAS #7440-47-3, CHROMIUM.
======================= Other Information =======================
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:TAN #23617 5 GALLON CAN
CAGE:3F338
CAGE:3F338
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL SPIRITS (VAPOR PRESSURE=.50) (LEL=1.0)
CAS:64475-85-0
RTECS #:PY8240000
Fraction by Wt: 14.40%
ACGIH TLV:100 PPM
ACGIH STEL:100 PPM
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:EYES/SKIN: LIQUID IS SLIGHTLY
IRRITATING. HIGH VAPOR CONCENTRATION MAY CAUSE IRRITATION.
PROLONGED/REPEATED SKIN CONTACT CAN CAUSE DEFATTING/DRYING OF SKIN
WHICH MAY RESULT IN SKIN IRRITATION/DERMATIT IS. INHAL: VAPORS MAY
IRRITATE NOSE/THROAT/RESPIRATORY TRACT. HIGH VAPOR CONCENTRATIONS
MAY CAUSE CNS DEPRESSION.
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN, AND
RESPIRATORY DISORDERS MAY BE AGGRIVATED BY EXPOSURE TO PRODUCT.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES, LIFTING LIDS TO RINSE
ENTIRE EYE. CALL DR IMMED. SKIN: REMOVE CONTAMINATED CLOTHING.
FLUSH W/COPIOUS AMOUNTS OF WATER, FOLLOWED BY SOAP & WATER. CALL
DR. DO NOTREUSE CLOTHING UNTIL CLEANED. INHALATION: REMOVE TO
FRESH AIR.APPLY CPR/OXYGEN IF NECESSARY. GET MED ATTN. INGESTION:
DON'T INDUCE VOMITING. IF VOMITING OCCURS, KEEP HEAD BELOW HIP
LEVEL TO PREVENT ASPIRATION OF LIQUID INTO LUNGS. CALL DR. *SEE
NOTES TO PHYSICIAN UNDER "OTHER INFORMATION" SECTION ON THIS MSDS.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:=51.7C, 125.F
Lower Limits:1.0
Upper Limits:6
Extinguishing Media:CO2
Fire Fighting Procedures:CAUTION: COMBUSTABLE! DO NOT ENTER CONFINED
FIRE SPACE WITHOUT FULL BUNKER GEAR INCLUDING NIOSH APPROVED SCBA.
COOL FIRE EXPOSED CONTAINERS W/H2O.
Unusual Fire/Explosion Hazard:CONTAINERS EXPOSED TO INTENSE HEAT SHOULD
BE COOLED W/H2O TO PREVENT VAPOR PRESSURE BUILD UP WHICH COULD
RESULT IN CONTAINER RUPTURE. CONTAINER AREAS EXPOSED TO DIRECT
FLAME SHOULD BE COOLED W/ LG QUA NTITIES H2O TO PREVENT WEAKING OF
CONTAINER STRUCTURE.
================== Accidental Release Measures ==================
Spill Release Procedures:CAUTION: COMBUSTABLE! LG SPILL: ELIMINATE
IGNITION SOURCES. WEAR APPROPRIATE RESPIRATOR/OTHER PROTECTIVE
CLOTHING. SHUT OFF LEAK ONLY IF SAFE TO DO. DIKE & CONTAIN. REMOVE
W/VACCUUM TRUCKS OR PUMP TO STORAGE/SALVAGE VESSELS. SOAK UP
RESIDUE W/ABSORBENT SUCH AS CLAY, SAND, OR OTHER SUITABLE MATERIAL.
PLACE IN NONLEAKING CONTAINERS & TIGHTLY SEAL FOR PROPER
DISPOSAL.**CONTINUED "OTHER PRECAUTIONS"
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL DRY AREA AWAY FROM
HEAT/SPARKS/ FLAME. CONTAINERS, EVEN EMPTY, CAN CONTAIN EXPLOSIVE
VAPORS. DO NOT CUT, DRILL, GRIND, WELD, OR PERFORM SIMILAR
OPERATIONS ON/NEAR CONTRS. STATIC ELECTRIC ITY MAY ACCUMULATE &
CREATE FIRE HAZARD. GROUND FIXED EQUIP. BOND & GROUND TRANSFER
CONTRS/EQUIP.
Other Precautions:**CONTINUED SPILL RELEASE:FLUSH SPILL AREA W/WATER TO
REMOVE TRACE RESIDUE. DISPOSE OF FLUSH SOLUTION AS ABOVE. SMALL
SPILLS: TAKE UP W/ABSORBENT MATERIAL IN CONTAINERS AS ABOVE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID PROLONGED/REPEATED BREATHING OF VAPORS. IF
EXPOSURE MAY OR DOES EXCEED OCCUPATIONAL EXPOSURE LIMITS, USE NIOSH
APPORVED RESPIRATOR TO PREVENT OVEREXPOSURE IN ACCORD W/29 CFR
1910.134. USE EITHER ATMOSPHERE SUPPLYING RESPIRATOR OR AIR
PURIFYING RESPIRATOR.
Ventilation:PROVIDE SUFFICIENT MECHANICAL VENT. TO MAINTAIN BELOW TLV
(8).
Other Protective Equipment:WEAR CHEMICAL PROTECTIVE CLOTHING.
Work Hygienic Practices:WASH W/ SOAP & WATER BEFORE EATING, DIRINKING,
SMOKING, APPLYING COSMETICS, OR USING TOILET FACILITIES. LAUNDER
CONTAM CLOTHING BEFORE REUSE. AIR DRY CONTAM CLOTHES IN WELL
VENTILTD AREA BEFORE WASHING
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:355 - 395 F
Vapor Density:>AIR
VOC Grams/Liter:1.96
Evaporation Rate & Reference:SLOWER THAN AIR
Appearance and Odor:LIQUID
Percent Volatiles by Volume:30.9
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID HEAT, FLAME, CONTACT W/ STRONG
OXIDIZING AGENTS.
Hazardous Decomposition Products:CO, AND UNIDENTIFIED ORGANIC COMPOUNDS
MAY BE FORMED DURING COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:UNDER EPA - RCRA (40CFR261.21). IF THIS PRODUCT
BECOMES WASTE MATERIAL, IT WOULD BE IGNITIBLE HAZ WASTE (D001).
REFER TO LATEST EPA OR STATE REGULATIONS REGARDING PROPER DISPOSAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PAINT, 85
Preparer's Name:JEFF ADLER
CAGE:EO503
CAGE:EO503
CAGE:16214
============= Composition/Information on Ingredients =============
Ingred Name:ING 7:RPTD EXPOS BY INHAL/ABSORPTION MAY CAUSE SYS
POISONING. CONTAINS METHYLENE CHLORIDE WHICH HAS BEEN SHOWN (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:TO CAUSE CANCER IN CERTAIN LAB ANIMAL TESTS.RISK TO
YOUR HLTH DEPENDS ON THE LEVEL & DURATION OF EXOS (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: REPORTS HAVE ASSOCD RPTD & PRLNGD OVEREXP TO SOLVS
W/PERM BRAIN & NERV SYS DAM. INTENTIONAL MISUSE BY (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: DELIB CONCENTRATING & INHALING THE CONTENTS MAY BE
HARMFUL OR FATAL.
RTECS #:9999999ZZ
Ingred Name:METHANOL; (METHYL ALCOHOL). VP: 96 @ 20C.
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 10%
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHANE, DICHLORO-; (METHYLENE CHLORIDE). VP: 355.000 @
20C.
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 80%
Other REC Limits:100 PPM (MFR)
OSHA PEL:500 PPM, C
ACGIH TLV:50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SOLVENT NAPHTHA; (AROMATIC HYDROCARBON BLEND). VP: 1.3 @
20C.
CAS:64742-94-5
RTECS #:WF3100000
Fraction by Wt: 5%
Other REC Limits:100 PPM
Ingred Name:VOC 9.751 LBS/GAL
RTECS #:9999999VO
Ingred Name:SUPP DATA:TEARING, REDNESS & SWELLING.INGEST:PROD IS HIGHLY
TOX BY INTEST. MAY CAUSE IRRIT OF DIGESTIVE TRACT, (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: SIGNS OF NERVS SYS DEPRESS (E.G. DROW, DIZZ, LOSS OF
COORDINATION & FATG). IT MAY ALSO CAUSE ABDOM PAIN, (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: VISUAL DISTURBANCES, BLINDNESS, CONVULSIONS, COMA
AND/OR DEATH. (ING 8)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:CHLOROCARBON MATLS HAVE PRODUCED SESIT
OF MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS & COULD HAVE SIMILAR
EFT IN HUMANS. ADRENOMIMETICS (E.G. EPINEPHRINE) MAY BE
CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINI NG USES IN HUMANS
ACUTELY/CHRONICALLY EXPOS TO CHLOROCARBONS . (EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:DICHLOROMETHANE: IARC GROUP 2B, NTP
ANTICIPATED TO BE A CARCINOGEN, ACGIH A2.
Effects of Overexposure:INHAL:IF POOR VENT, MAY CAUSE UNCON &
ASPHYXIATION. HARMFUL IF INHALED. MAY AFFECT BRAIN/NERVS SYS
CAUSING DIZZ, HDCH/NAUS. PROD REDUCES BLOOD OXYGEN-CARRYING
CAPACITY. SKIN: PRLNGD/RPTD CONT MAY CAUS E DRYING, CRACKING/IRRIT.
PROD IS READILY ABSORBED THRU SKIN IN HARMFUL AMTS. SIGNS & SYPMS
OF TOX ARE SIM (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. RESTORE BREATHING. TREAT
SYMPTOMATICALLY. CONSULT MD. SKIN: REMOVE CONTAMD CLTHG. WASH
AFFECTED AREAS THORO W/SOAP & WATER. CONSULT MD IF IRRIT PERSISTS.
EYE:FLUSH IMMED W/L G AMTS OF WATER FOR @ LST 15 MIN. TAKE TO MD
FOR MED TREATMENT. INGEST: DRINK 1 OR 2 GLASSES OF WATER TO DILUTE.
DO NOT INDUCE VOMIT. CONSULT MD OR POISON CONTROL CENTER IMMED.
TREAT SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:54.0F,12.2C
Lower Limits:0.8%
Upper Limits:36.5%
Extinguishing Media:SM:DRY CHEM/CARBON DIOXIDE/WATER SPRAY/ALCOHOL
FOAM. LG:DRY CHEM/ALCOHOL/UNIVERSAL FOAM IS REC.FLOOD W/WATER (SUPP
DATA)
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD PRESS DEMAND SCBA &
FULL PROT EQUIP .WATER SPRAY MAY BE USEFUL IN MINIMIZING VAPS &
COOLING CNTNRS EXPOS TO HEAT & (SUPP DATA)
Unusual Fire/Explosion Hazard:FLASHBACK ALONG VAP TRAIL MAY OCCUR. MATL
MAY BE IGNITED BY HEAT, SPKS, FLAME/STATIC ELEC. CLSD CNTNRS MAY
EXPLODE WHEN EXPOS TO EXTREME HEAT. (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION (FLAMES, HOT
SURFACES AND ELECTRICAL STATIC, OR FRICTIONAL SPARKS). AVOID
BREATHING VAPORS. VENTILATE AREA. REMOVE WITH INERT ABSORBENT AND
NON-SPARKING TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE OR USE NEAR HEAT, SPARKS,
OR FLAMES.
Other Precautions:DO NOT TAKE INTERNALLY. ADD LABEL WARNING. AVOID
BREATHING SANDING DUST. NO SMOKING IN AREA OF USE. DO NOT USE IN
GENERAL VICINITY OF ARC WELDING, OPEN FLAMES/HOT SURFS. HEAT &/UV
RADIATION MAY CAUSE FORMATION OF HCL &/PHOSGENE .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN RESTRICTED VENTILATION AREAS USE NIOSH/MSHA
APPROVED CHEMICAL MECHANICAL FILTERS DESIGNED TO REMOVE GAS AND
VAPOR. IN CONFINED AREAS USE A BUREAU OF MINES AIR LINE TYPE
RESPIRATORS OR HOODS (NIOSH/ MSHA APPROVED).
Ventilation:PROVIDE GEN DILUTION OF LOC EXHST VENT IN VOL & PATTERN TO
KEEP TLV OF HAZ INGS LISTED < ACCEPTABLE LIM & LEL(SUPP DATA)
Other Protective Equipment:PROTECTIVE OVERALLS THAT WILL PREVENT
CLOTHING CONTAMINATION.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING WASHROOM.
SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
EXTING MEDIA:FROM SAFE DISTANCE. FIRE FIGHT PROC:FLAME. AVOID SPREADING
BURNING LIQ W/WATER USED FOR COOLING PURPOSES. EXPLO HAZ:THERMAL
DECOMP PRODS MAY INCLUDE HCL & PHOSGENE . VENT:< STATED L IM. EFTS
OF OVEREXP: TO THOSE OF SWALLOWING. EYE: IRRITANT. DIRECT CONT
W/LIQ/EXPOS TO ITS VAP/MISTS MAY CAUSE (ING 5)
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:>104F,>40C
Vapor Density:HVR/AIR
Spec Gravity:1.194 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:12.8% OF TOTAL WT
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:97.6
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTAMINATION WITH STRONG OXIDIZING AGENTS AND ALKALIES.
Stability Condition to Avoid:DO NOT STORE ABOVE 120F.
Hazardous Decomposition Products:FUMES MAY CONTAIN CARBON DIOXIDE
AND/OR CARBON MONOXIDE. HCL, PHOSGENE (FP P).
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W LOCAL, STATE AND FEDERAL
REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ASBESTOS-FREE, SERVO SEGMENTS (AFD)
Preparer's Name:E L ROGERS
CAGE:0B7T5
CAGE:76126
CAGE:0B7T5
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM OXIDE; (ALPHA ALUMINUM OXIDE) (SARA 313)
CAS:1344-28-1
RTECS #:BD1200000
Fraction by Wt: <1.5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9495
Ingred Name:BARIUM SULFATE
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: 5-20%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9495
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9495
Ingred Name:CARBON; (GRAPHITE (SYNTHETIC))
CAS:7440-44-0
RTECS #:FF5250100
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MAGNESIUM OXIDE
CAS:1309-48-4
RTECS #:OM3850000
OSHA PEL:15 MG/M3 PARTICULATE
ACGIH TLV:10 MG/M3; FUME; 9495
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9495
Ingred Name:GRAPHITE; (GRAPHITE (NATURAL))
CAS:7782-42-5
RTECS #:MD9659600
OSHA PEL:15 MPPCF; Z-3
ACGIH TLV:2 MG/M3 RDUST; 9495
Ingred Name:SILICATES (INCLUDING GLASS FIBERS)
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:IRON OXIDE
CAS:1309-37-1
RTECS #:NO7400000
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5MG(FE)/M3FUME,B2;95
Ingred Name:ZINC OXIDE (SARA 313) (CERCLA)
CAS:1314-13-2
RTECS #:ZH4810000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9495
Ingred Name:ALUMINUM (SARA 313)
CAS:1344-28-1
RTECS #:BD1200000
OSHA PEL:15 MG/M3 DUST
ACGIH TLV:10 MG/M3 DUST; 9495
Ingred Name:FIBROUS GLASS
RTECS #:LK3651000
OSHA PEL:15 MG/M3, DUST
ACGIH TLV:10 MG/M3, DUST; 9495
Ingred Name:POLY(IMINO-1,4-PHENYLENEIMINOCARBONYL-1,4-
PHENYLENECARBOXY)POLY(IMINO-P-PHENYLENEIMINOTEREPHTHYALOYL);
(ARAMID)
CAS:24938-64-5
RTECS #:TQ9875000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL WOOL; (ROCK WOOL (MINERAL WOOL))
RTECS #:PY8070000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WOLLASTONITE
CAS:13983-17-0
RTECS #:ZC9750000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICATE, MICA; (MICA)
CAS:12001-26-2
RTECS #:VV8760000
OSHA PEL:20 MPPCF; Z-3
ACGIH TLV:3 MG/M3 RDUST; 9495
Ingred Name:INERT (NUISANCE) DUST
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CURED PHENOLIC AND CASHEW RESINS
OSHA PEL:10 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:IRON OXIDE
CAS:1309-37-1
RTECS #:NO7400000
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5MG(FE)/M3FUME,B2;95
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST;9495
Ingred Name:SUPDAT:PRDCE SILICOSIS. IARC HAS CLASSIFIED PURE
CRYSTALLINE SILICA AS POSS CARCIN. METAL DUSTS CAN BE IRRIT OF(ING
22)
RTECS #:9999999ZZ
Ingred Name:ING 21:EYES & UPPER RESP SYS. THERE IS LITTLE KNOWN EVID OF
CHRONIC INDUS POISONING FROM IRON, ALUMINUM, & ZINC DUSTS.
RTECS #:9999999ZZ
Ingred Name:EXP OF CARCIN:CARCINOGENS, 1994: ANTIC TO BE CARCIN.
FIBROUS GLASS & MINERAL WOOL: IARC GROUP 2B, VOL 43, P 152, 1988.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:REPLACED CNTNS ASBESTOS FIBERS, IT IS SUGGESTED
THAT WORKER FOLLOW "RECOMMENDED PROCEDURES" HELD BY (ING 25)
RTECS #:9999999ZZ
Ingred Name:ING 24:FRICTION MATERIALS STANDARDS INSTITUTE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: PARTIALLY CURED CASHEW
RESINS-SKIN ERUPTIONS SIMILAR IN APPEARANCE TO POISON IVY. LUNG
EFFECTS FROM ASBESTOS AND CRYSTALLINE SILICA-COUGHING, WHEEZING,
SHORTNESS OF BREATH, IMPAIRED PULMONARY F UNCTION. DUSTS IN EYE MAY
CAUSE IRRITATION. GASTROINTESTINAL DISTURBANCES POSSIBLE FROM
INGESTION. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC
MONOGRAPHS, SUPPLEMENT. VOL 7, PG 341, 1987:GROUP 2A. NTP 7TH
ANNUAL RPT ON (ING 23)
Effects of Overexposure:HLTH HAZ:CHRONIC:THIS PROD DOES NOT CNTN
ASBESTOS. HOWEVER, IT MAY CONTAIN SUCH NON- ASBESTOS FIBERS AS
ARAMID, FIBERGLASS WOLLASTONITE, ROCK WOOL/OTHER MANMADE/MINERAL
FIBERS. WHILE WE ARE NOT AWARE OF ANY SPECIFIC HLTH HAZS CAUSED BY
EXPOS TO DUST FROM FRICTION MATLS CNTNG THESE FIBERS, GEN STUDIES
OF VERY(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SHOULD NOT BE NECESSARY FROM A PROPER HANDLING OF THIS
FRICTION MATERIAL PRODUCT. INGEST:CALL MD IMMEDIATELY .
INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP) .
EYES:IMME DIATELY FLUSH W/POTABLE WATER FOR A MINIMUM OF 15
MINUTES, SEEK ASSISTANCE FROM MD . SKIN:FLUSH W/COPIOUS AMOUNTS OF
WATER. CALL MD .
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER (ABC EXTINGUISHER), FOG OR FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT APPLICABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:REFER TO SECTION 7 (SPECIAL PRECAUTIONS).
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:WHILE WORKING W/FRICTION MATLS, DO NOT
GENERATE DUST. DO NOT USE AIR HOSE/BRUSH TO REMOVE DUST. DO NOT
BRTHE DUST.
Other Precautions:VACUUM EQUIPPED W/HIGH EFFICIENCY PARTICULATE AIR
(HEPA) FILTER TO REMOVE DUST/WEAR RESP AS APPRVD BY NIOSH/MSHA FOR
PROT AGAINST INHAL OF DUST & FIBERS. BECAUSE MECH MAY NOT KNOWN
WHETHER BREAK WEARDEBRIS & WORN-OUT LINING BEING(ING 24)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER NORMAL CONDITIONS. HOWEVER,
IF CONCENTRATION OF AIRBORNE ASBESTOS FIBERS IN EXCESS OF OSHA
STANDARD IS CREATED, RESPIRATOR APPROVED BY NIOSH/MSHA FOR ASBESTOS
FIBERS SHOULD BE USED.
Ventilation:LOCAL EXHAUST: PREFERRED DURING ALL OPERATIONS WHICH MIGHT
GENERATE DUST-INCLUDING GRINDING AND DRILLING.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:FINE RESPIRABLE FIBERS PHYSICALLY SIMILAR IN DIAMETER &
LENGTH TO ABESTOS INDICATED THE POSSIBILITY OF CHRONIC LUNG
DISEASE, INCL FIBROSIS, W/OVEREXP. SOME PERS MAY BE SENSITIVE TO
PAR TIALLY CURED PHENOLIC/CASHEW RESINS & DEVELOP DERM-TYPE RXNS
UPON SKIN CONT. DUSTS OF CRYSTALLINE SILICA MAY (ING 21)
================== Physical/Chemical Properties ==================
Spec Gravity:1.6-3.7(H*2O=1)
Evaporation Rate & Reference:0
Solubility in Water:NO
Appearance and Odor:SOLID, ODORLESS, LIGHT TAN TO DARK GREY (METALLIC)
COLOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION WILL CREATE
CARBON MONOXIDE AND CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN PROPER RECEPTACLES APPROPRIATELY
LABELLED IN ACCORDANCE WITH APPLICABLE FEDERAL, STATE AND LOCAL
LAWS AND REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:INTERLUX RUBBER EFFECT VARNISH, 60
CAGE:26351
CAGE:26351
============= Composition/Information on Ingredients =============
Ingred Name:VM&P NAPHTHA (LIGROINE)
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 1-5%
OSHA PEL:300 PPM/400 STEL
ACGIH TLV:300 PPM; 9192
Ingred Name:SOLVENT NAPHTHA,PETROLEUM LIGHT AROMATIC (CAS# 64742-95-6)
(15-20%)
ACGIH TLV:100 PPM (MFR)
Ingred Name:VM&P NAPHTHA (LIGROINE)
CAS:8032-32-4
RTECS #:OI6180000
OSHA PEL:300 PPM/400 STEL
ACGIH TLV:300 PPM; 9192
Ingred Name:METHYL ISOBUTYL KETONE (SARA III)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 1-5%
OSHA PEL:100 PPM/75 STEL
ACGIH TLV:50 PPM/75 STEL; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:EYES:SEVERE IRRIT,RED,TEAR,BLUR
VISION.SKIN:IRRIT,POSS DERMATITIS.INHAL:RESP TRACT (SEE SUPP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH IMMED W/COPIOUS QUANT OF H*2O FOR @ LEAST 15
MIN.GET IMMED MED ATTN.SKIN:RMV CONTAM CLTHG,WASH W/SOAP,H*2O.WASH
CLOTHES BEFORE REUSE.INHAL:RMV TO FRESH AIR.GIVE ARTF RESP IF
NEEDED.CALL DR. INGEST:CALL DR IMMED TO DETERMINE IF INDUCE VOMIT.
===================== Fire Fighting Measures =====================
Flash Point:100F (37.8C)
Lower Limits:1.2
Extinguishing Media:FOAM,CO*2,DRY CHEMICAL
Fire Fighting Procedures:USE H*2O TO COOL CLSD CNTNRS,NOT AS EXT
MEDIA.(SEE SUPP DATA
Unusual Fire/Explosion Hazard:CONTAINS FLM SLVT.DONT USE WHERE
SPARK/OPEN FLM ARE PRESENT.CLSD CNTNRS MAY EXPLO IF EXP TO EXT HEAT
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION.AVOID PROLONG
INHALATION OF VAPORS.VENTILATE AREA.CLEAN UP W/ABSORBANT MATERIALS.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BRTHG DUST/CHIPS FROM
SANDING/BLASTING SURFACE COATED W/PROD.STORE IN BLDG
DESIGNED,PROTECTED FOR STORAGE OF OF NFPA COMBUSTIBLE,CLASS II
LIQUID
Other Precautions:CHRONIC OVEREXP TO, + MISUSE OF,SLVTS LINKED TO PERM
BRAIN & NERVOUS SYSTEM DAMAGE. VENTILATION: WELD/FLAME CUT ON
SURFACE COATED WITH THIS PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH.MSHA APPROVED RESP PROT DEPENDING ON
CONDITION OF USE.
Ventilation:SUFF VENT TO KEEP < TLV,RMV DECOMP PROD IF (SEE OTHR
PRECAUT
Other Protective Equipment:FACE SHIELD TO PVNT EYE CONT.IMPERVIOUS
PROTECTIVE CLOTHING.
Supplemental Safety and Health
OVEREXP
EFTS:IRRIT,HEADACHE,DIZZINESS,UNCONSCIOUSNESS.INGEST:GASTROINTESTIN
AL IRRIT,NAUSEA,VOMITING,DIARRHEA. SPECIAL FIRE FIGHT PROC:DONT
SPREAD BURNING LIQUID W/H*2O. DATE OF PREP:7/21/86.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:241-325F
Vapor Density:> 1
Spec Gravity:0.9255
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:63
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
Stability Condition to Avoid:STORE AWAY FROM DIRECT HEAT,FLAME/SPARK.
Hazardous Decomposition Products:CO,CO*2,VARIOUS HYDROCARBON FRAGMENTS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IAW FEDERAL,STATE & LOCAL REGULATIONS.DO
NOT INCINERATE UNOPENED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ADHESIVE FA-8/8A-5 FREEZE PAK
Kit Part:Y
CAGE:99098
CAGE:99098
============= Composition/Information on Ingredients =============
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS >4000MG/KG-INGRED #1
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:MAY CAUSE IRRITATION.SKIN:MAY
CAUSE IRRITATION OR SENSITIZATION.INGEST:SLIGHTLY TOXIC.MAY CAUSE
GI TRACT IRRITATION.INHAL:MAY CAUSE RESPIRATORY IRRITATION OR
SENSITIZATION.
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of
Overexposure:INHAL:HEADACHE,NAUSEA,DIZZINESS.SKIN:REDNESS,SWELLING.
EYES:REDNESS(ESP.FROM THE VAPORS WHEN HEATED).
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN AND
RESPIRATORY AILMENTS MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH SOAP AND
WATER.EYES:FLUSH WITH WATER FOR 15 MINUTES.INHAL:REMOVE TO FRESH
AIR.GIVE OXYGEN OR ARTIFICIAL RESPIRATION IF NEEDED.INGEST:DO NOT
INDUCE VOMITING. GET PROMPT QUALIFIED MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:300F,149C
Extinguishing Media:WATER FOG,DRY CHEMICAL,CARBON DIOXIDE,ALCOHOL FOAM.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.COOL FIRE EXPOSED CONTAINERS WITH WATER
FOG.
Unusual Fire/Explosion Hazard:POSSIBLE EXOTHERMIC REACTION(HEAT IS
GIVEN OFF) WHEN MORE THAN 1GAL IS HEATED ABOVE 400F.
================== Accidental Release Measures ==================
Spill Release Procedures:THIS ITEM IS USUALLY DISPENSED IN QUANTITIES
OF LESS THAN 10ML.SCOOP UP EXCESS;CURE REMAINDER;PLACE IN METAL
CONTAINER PENDING DISPOSAL.WASH SPILL AREA WITH SOAP AND WATER.DO
NOT CONTAMINATE WATERWAYS WITH UNCURED MATERIAL.
Neutralizing Agent:CURED MATERIAL IS NON-HAZARDOUS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY,WELL-VENTILATED
PLACE.KEEP CONTAINER CLOSED WHEN NOT IN USE.KEEP AWAY FROM
HEAT,SPARKS,FLAMES AND INCOMPATIBLE MATERIALS.
Other Precautions:FOLLOW LABEL DIRECTIONS.AVOID BREATHING VAPORS.AVOID
SKIN AND EYE CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE ENVIRONMENTAL CONTROLS ARE LACKING OR IN
ENCLOSED SPACES USE EITHER A SELF-CONTAINED BREATHING APPARATUS OR
A NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC VAPORS,DEPENDING ON
THE AIRBORN CONCENTRA TION.
Ventilation:USE LOCAL EXHAUST.
Other Protective Equipment:PROTECTIVE CLOTHING,AS NEEDED.PROVIDE A
LOCAL EYE WASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS.SEPERATE WORK CLOTHES FROM STREET
CLOTHES.LAUNDER WORK CLOTHES BEFORE REUSE.KEEP FOOD OUT OF THE WORK
AREA.
Supplemental Safety and Health
KEY1;N1.HMIS SPOKE TO KIRAN PATEL.HE INFORMED US THAT THIS PRODUCT
ALREADY CONTAINS THE CATALYST.IT HAS BEEN
PREMIXED,DEGASSED,TESTED,THEN FROZEN ON DRY ICE.HMIS HAS INCLUDED
THE ACTIVATOR BA-5(PNIND- B) FOR INFORMATIONAL PURPOSES.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:260F,127C
Vapor Density:>1
Spec Gravity:1.18
Viscosity:6000 CPS
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:PARTIALLY MISCIBLE
Appearance and Odor:LIQUID;BLUE-GREEN;ETHER/AMMONIA ODOR.
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS,ACIDS,MERCAPTANS,BASES,AMONES(ESP.WHERE THERE
IS MORE THAN 1 POUND).
Stability Condition to Avoid:HIGH HEAT ABOVE 400F,SOURCES OF IGNITION.
Hazardous Decomposition Products:CARBON DIOXIDE,CARBON MONOXIDE,OXIDES
OF NITROGEN,ALDEHYDES AND UNIDENTIFIED ORGANIC COMPOUNDS.
Conditions to Avoid Polymerization:WHERE THERE IS MORE THAN 1 POUND OF
MATERIAL, THIS MATERIAL WILL POLYMERIZE WHEN HEATED ABOVE 400F.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:148 8485,KODAK BLACK DEVELOPER K2
Preparer's Name:NOT PROVIDED
CAGE:19139
CAGE:EO274
CAGE:0ZW37
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:FERRITE (CONTAINING INGREDIENT 2, COPPER COMPOUNDS AND
INGREDIENT 3, ZINC COMPOUNDS)
Minumum % Wt:90.
Maxumum % Wt:95.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
Ingred Name:COPPER COMPOUNDS
< Wt:15.
Other REC Limits:NOT PROVIDED
OSHA PEL:1 MG/M3 (CU DUST)
ACGIH TLV:1 MG/M3 (CU DUST)
Ingred Name:ZINC COMPOUNDS
< Wt:15.
Other REC Limits:NOT PROVIDED
OSHA PEL:15 MG/M3 (TDUST)
ACGIH TLV:10 MG/M3 (TDUST)
Ingred Name:POLYESTER RESIN
CAS:39382-25-7
Minumum % Wt:3.
Maxumum % Wt:10.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
< Wt:1.
Other REC Limits:NOT PROVIDED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT PROVIDED
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EFFECTS OF EXPOSURE: INHALATION:
EXPECTED TO BE A LOW HAZARD FOR RECOMMENDED HANDLING. EYES: NO
SPECIFIC HAZARD KNOWN. MAY CAUSE TRANSIENT IRRITATION. SKIN:
EXPECTED TO BE A LOW HAZARD FOR RECOMMENDED HANDLING. INGESTION:
EXPECTED TO BE A LOW INGESTION HAZARD. OVEREXPOSURE TO CARBON BLACK
DUST MAY RESULT IN IRRITATION OF THE RESPIRATORY TRACT AND BENIGN
DEPOSITION OF CARBON BLACK IN THE LUNG.
Explanation of Carcinogenicity:- CARCINOGENICITY CLASSIFICATION
(COMPONENTS PRESENT AT 0.1% OR MORE): -INTERNATIONAL AGENCY FOR
RESEARCH ON CANCER (IARC) (CARBON BLACK): 2B - AMERICAN CONFERENCE
OF GOVERNMENTAL INDUSTRIAL HYGIENIST S (ACGIH): NONE - NATIONAL
TOXICOLOGY PROGRAM (NTP): NONE - OCCUPATIONAL SAFETY AND HEALTH
ADMINISTRATION (OSHA): NONE
Effects of Overexposure:EYES: MAY CAUSE TRANSIENT IRRITATION.
Medical Cond Aggravated by Exposure:NOT PROVIDED
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. TREAT
SYMPTOMATICALLY. GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. EYES:
ANY MATERIAL THAT CONTACTS THE EYE SHOULD BE WASHED OUT IMMEDIATELY
WITH WATER. G ET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH
WITH SOAP AND WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION.
NEVER GIVE ANYTHING BY M OUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE (CO2), DRY CHEMICAL.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:POWDERED MATERIAL MAY FORM EXPLOSIVE
DUST-AIR MIXTURES.
================== Accidental Release Measures ==================
Spill Release Procedures:DO NOT USE A VACUUM CLEANER TO CLEAN UP SPILLS
OF POWDERED DEVELOPERS AND TONERS. THE VERY FINE PARTICLES CAN
CAUSE A FIRE OR EXPLOSION. SWEEP MATERIAL ONTO PAPER AND PLACE IN A
FIBER CARTON. AVOID GE NERATION OF DUST.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. POWDERED
MATERIAL MAY FORM EXPLOSIVE DUST-AIR MIXTURES. MINIMIZE DUST
GENERATION AND ACCUMULATION. KEEP AWAY FROM SOURCES OF IGNITION.
KEEP FROM CONTACT WITH OXIDIZING MATERIALS .
Other Precautions:AVOID BREATHING DUST. USE WITH ADEQUATE VENTILATION.
WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD VENTILATION (TYPICALLY 4-6 ROOM VOLUMES PER HOUR)
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS.
Other Protective Equipment:WASHING FACILITIES.
Work Hygienic Practices:IT IS A GOOD INDUSTRIAL HYGIENE PRACTICE TO
MINIMIZE EYE CONTACT.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NOT RELEVANT
Melt/Freeze Pt:M.P/F.P Text:100-150 C (212-302 F)
Vapor Pres:NEGLIGIBLE
Vapor Density:NOT APPLIC
Spec Gravity:4.0-5.0
Evaporation Rate & Reference:NOT PROVIDED
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACKD SOLID (POWDER), SLIGHT ODOR
Percent Volatiles by Volume:NEGLIGIBLE
Corrosion Rate:NOT PROVIDED
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NOT PROVIDED
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
OXIDES OF IRON, OXIDES OF COPPER, OXIDES OF ZINC.
=================== Toxicological Information===================
Toxicological Information:EFFECTS OF EXPOSURE: INHALATION: EXPECTED TO
BE A LOW HAZARD FOR RECOMMENDED HANDLING. EYES: NO SPECIFIC HAZARD
KNOWN. MAY CAUSE TRANSIENT IRRITATION. SKIN: EXPECTED TO BE A LOW
HAZARD FOR RECOMMENDED HANDLING. INGESTION: EXPECTED TO BE A LOW
INGESTION HAZARD. OVEREXPOSURE TO CARBON BLACK DUST MAY RESULT IN
IRRITATION OF THE RESPIRATORY TRACT AND BENIGN DEPOSITION OF CARBON
BLACK IN THE LUNG.
===================== Ecological Information =====================
Ecological:THIS MATERIAL HAS NOT BEEN TESTED FOR ENVIRONMENTAL EFFECTS.
IN A SPILL SITUATION THIS MATERIAL MAY BE VISUALLY UNPLEASANT;
HOWEVER, IT IS NOT EXPECTED TO CAUSE ADVERSE ENVIRONMENTAL EFFECTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR LANDFILL. CAN BE INCINERATED WHEN
IN COMPLIANCE WITH LOCAL REGULATIONS. DISCHARGE, TREATMENT. OR
DISPOSAL MAY BE SUBJECT TO NATIONAL, STATE, OR LOCAL LAWS.
=================== MSDS Transport Information ===================
Transport Information:FOR TRANSPORTATION INFORMATION REGARDING THIS
PRODUCT CALL THE KODAK WORLDWIDE TRANSPORTATION HAZMAT HOT LINE:
(800) 255-3434 BETWEEN 8 A.M. AND 5 P.M. (EASTERN STANDARD TIME),
MONDAY THROUGH FRIDAY.
===================== Regulatory Information =====================
SARA Title III Information:CHEMICAL(S) SUBJECT TO THE REPORTING
REQUIREMENTS OF SECTION 313 OF TITLE III OF THE SUPERFUND
AMENDMENTS AND REAUTHORIZATION ACT (SARA) OF 1986 AND 40 CFR PART
372: COPPER COMPOUNDS, ZINC COMPOUNDS
Federal Regulatory Information:NOT PROVIDED
State Regulatory Information:MATERIAL(S) KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER: NONE. MATERIAL(S) KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE ADVERSE REPRODUCTIVE EFFECTS: NONE.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SA 827 3149,MIL-L-46000B
CAGE:1F469
CAGE:70878
CAGE:1F469
============= Composition/Information on Ingredients =============
Ingred Name:LITHIUM STEARATE (SPECIFICATION REQUIRES 8.0% + OR - 0.3
CAS:4485-12-5
RTECS #:WI4370000
Ingred Name:BIS (2-ETHYLEXYL) SEBACATE (SPECIFICATION REQUIRES 89.0% +
OR - 1.0)
CAS:122-62-3
RTECS #:VS1000000
Ingred Name:DIISOPROPYL PHOSPHITE (SPECIFICATION REQUIRES 1.0% + OR -
0.2)
CAS:1809-20-7
RTECS #:SZ7660000
Ingred Name:2,6-DI-TERT-BUTYL-P-CRESOL
CAS:128-37-0
RTECS #:GO7875000
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3; 9192
Ingred Name:BARIUM DINONYLNAPHTHALENE SULFONATE (SPEC. REQUIRES 1.5% +
OR - 0.3) SEE SUPP DATA
===================== Hazards Identification =====================
Effects of Overexposure:SKIN IRRIT ON PROLONGED CONTACT.SEVERE EYE
BURNS. MAY CAUSE RESP IRRIT,DIZZ,NAUSEA & LOSS OF CONSCSN
======================= First Aid Measures =======================
First Aid:FLUSH EYES IMMEDIATELY W/WATER @ LEAST 15 MIN.CALL MD
IMMEDIATELY. WASH SKIN THOROUGHLY W/SOAP & WATER. IF OVERCOME BY
VAPORS,MOVE FROM CONTAMINATED AREA.IMMED CALL MD. IF INGESTED,DO
NOT INDUCE VOMIT ING.CALL MD IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:172F,78C COC
Extinguishing Media:DRY CHEM,CO*2,FOAM,WATERFOG,SAND & EARTH
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS SHOULD BE
WORN.
Unusual Fire/Explosion Hazard:DENSE SMOKE
================== Accidental Release Measures ==================
Spill Release Procedures:TRANSFER BULK OF MATERIAL INTO ANOTHER
CONTAINER.ABSORB REMAINDER W/PROPER ABSORBENTS SUCH AS
SAND,EARTH,VERMICULITE.SWEEP UP AND DISPOSE AS SOLID WASTE IN
ACCORDANCE W/LOCAL,STATE,& FEDERAL REGULATIO NS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED.AVOID CONTACT
W/SKIN,EYES & CLOTHING.WASH THOROUGHLY AFTER HANDLING.WASH CLOTHING
BEFORE REUSE.
Other Precautions:KEEP AWAY FROM FEED AND FOOD PRODUCTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MFR STATES NONE REQUIRED
Ventilation:GENERAL MECHANICAL
Supplemental Safety and Health
OIL-FREE BARIUM PETROLEUM SULFONATE W/AVG MOLECULAR WGT OF > 1090 IS
ACCEPTABLE IN LIEU OF BARIUM DINONYLNAPHTHALENE SULFONATE. BOILING
PT BASED ON DIISOPROPYL PHOSPHITE.
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:160F
Spec Gravity:0.921
Solubility in Water:SLIGHT
Appearance and Odor:AMBER VISCOUS LIQUID W/BLAND ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS SUCH AS:CHROMIC ACID,BROMINE,HYDROGEN PEROX
Hazardous Decomposition Products:CO,CO*2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE W/LOCAL,STATE,AND FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:4-1080 DUAL PURPOSE ELECTROSTATIC SOLUTION
Preparer's Name:KENNETH W. PINTER
CAGE:17638
CAGE:17638
CAGE:9C980
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM FERROCYANIDE
CAS:13746-66-2
RTECS #:LJ8225000
Fraction by Wt: 2-3% %
Other REC Limits:NONE SPECIFIED
ACGIH TLV:5 MG/M3
Ingred Name:GLYCERIN
CAS:56-81-5
RTECS #:MA8050000
Fraction by Wt: 5-10% %
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 (MIST) 9293
Ingred Name:NON HAZARDOUS INGREDIENTS
Fraction by Wt: BALANCE
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT):12,600 MG/KG (GLYCERINE)
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SOME EYE IRRITATION UPON
CONTACT.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:NO KNOWN HEALTH HAZARDS EXCEPT SOME EYE
IRRITATION UPON CONTACT.
Medical Cond Aggravated by Exposure:NONE KNOWN
===================== Fire Fighting Measures =====================
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP WITH DRY OR DAMP CLOTH.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:SOLUTIONS MAY FREEZE AND SHOULD BE
BROUGHT TO ROOM TEMPERATURE AND SHAKEN VIGOROUSLY BEFORE USING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHEN USED AS DIRECTED.
Ventilation:MECHANICAL(GENERAL) IS ACCEPTABLE.
Other Protective Equipment:NONE REQUIRED WHEN USED AS DIRECTED.
Work Hygienic Practices:WASH THOROUGHLY AFTER USE AND BEFORE EATING OR
SMOKING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:20.0F,-6.7C
Vapor Pres:20
Vapor Density:0.6
Spec Gravity:1.104
pH:4.3
Evaporation Rate & Reference:NO DATA
Solubility in Water:COMPLETE
Appearance and Odor:GREEN LIQUID, NO ODOR
Percent Volatiles by Volume:80-85
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Stability Condition to Avoid:STORAGE NEAR ACIDS
Hazardous Decomposition Products:CONTACT WITH ACIDS OR ACIDIC MATERIALS
MAY GENERATE HYDROGEN CYANIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL AND STATE
REGULATIONS FOR WATER SOLUBLE MATERIALS CONTAINING SMALL AMOUNTS OF
COMPLEXED CYANIDE.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:THOROSEAL FOUNDATION COATING
Preparer's Name:C.G. LOPEZ
CAGE:1DM95
CAGE:1DM95
============= Composition/Information on Ingredients =============
Ingred Name:SILICA DIOXIDE, CRYSTALLINE QUARTZ, SAND (SUSPECTED HUMAN
CARCINOGEN BY IARC & ACGIH)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 42-47%
Other REC Limits:0.05 MG/CUM NIOSH
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:CALCIUM HYDROXIDE, LIME, CALCIUM HYDRATE
CAS:1305-62-0
RTECS #:EW2800000
Fraction by Wt: <5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:5 MG/M3; 9293
Ingred Name:ORGANIC COMPOUNDS(TYPE NOT SPECIFIED)
Fraction by Wt: <53%
Ingred Name:INORGANIC MATERIALS (NOT SPECIFIED)
Fraction by Wt: <53%
Ingred Name:CEMENT,(TYPE NOT SPECIFIED)
Fraction by Wt: <53%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INGESTION: DIGESTIVE TRACT IRRITATION.
EYES: IRRITATION, BURNING & ABRASIONS OF THE CORNEA. SKIN: DRYNESS,
ITCHING, RASHES, BURNS, ABRASION.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:SKIN: DERMATITIS & SENSITIZATION. INHALATION:
IRREVERSIBLE FIBROSIS OF THE LUNGS (SILICOSIS). RESPIRATORY TRACT
IRRITATION & DAMAGE TO THE MUCOUS MEMBRANES OF THE UPPER
RESPIRATORY TRACT.
======================= First Aid Measures =======================
First Aid:SKIN: RINSE W/WATER, THEN WASH W/SOAP & WATER. DON'T RUB
UNTIL SKIN IS FREE OF MATERIAL. EYES: RINSE W/PLENTY OF WATER FOR
AT LEAST 15 MINS. DON'T RUB EYES. INGESTION: GIVE ONE OR TWO
GLASSES OF WATER TO DRINK. INHALATION: REMOVE TO FRESH AIR. NOTE
TO PHYSICIAN: MUCOUSAL INJURY FOLLOWING INGESTION MAY
CONTRAINDICATE INDUCTION OF VOMITING FOR TREATMENT OF INGESTION.
OBTAIN MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:PRODUCT WILL NOT BURN.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP UNNECESSARY PEOPLE AWAY. WEAR PERSONAL
PROTECTION. COLLECT SPILLED POWDER BY DUSTLESS METHODS & PLACE IN
CONTAINERS. DIKE SPILL OF MIXED MATERIAL W/ABSORBENT MATERIAL &
SHOVEL INTO WASTE CONTAINE RS. WET MATERIAL MAY BE SLIPPERY.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY AREA OFF GROUND.
MINIMIZE GENERATION OF DUSTS. INGREDIENTS ARE STONGLY ALKALINE WHEN
MIXED W/WATER.
Other Precautions:AVOID SKIN & EYE CONTACT. AVOID BREATHING DUSTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR DUST WHEN
EXPOSURE LIMITS AE EXCEEDED
Ventilation:LOCAL EXHAUST TO KEEP BELOW APPLICABLE EXPOSURE LIMITS
Other Protective Equipment:SAFETY GLASSES, EYEWASH STATION
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
ALL INGREDIENTS HAVE EXTREMELY HIGH MELTING & BOILING POINTS.
================== Physical/Chemical Properties ==================
Solubility in Water:SLIGHT
Appearance and Odor:DARK GRAY POWDERED SOLID W/NO PARTICULAR ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS ORGANIC & INORGANIC ACIDS. ACIDS WILL
REACT W/CEMENT, LIME & CARBONATES. WATER.
==================== Disposal Considerations ====================
Waste Disposal Methods:REUSE POWDER OR MIXED MATERIAL IF
UNCONTAMINATED. DISCARDED PRODUCT & HARDENED MORTAR ARE
NON-HAZARDOUS WASTES UNDER RCRA. DISPOSE OF NONHAZARDOUS WASTE IN
ACCORDANCE W/FEDERAL, STATE, & LOCAL REGULAT IONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1-ACETYL-2-PHENYLHYDRAZINE, A4626
CAGE:21076
CAGE:21076
============= Composition/Information on Ingredients =============
Ingred Name:1-ACETYL-2-PHENYLHYDRAZINE
CAS:114-83-0
RTECS #:AJ2900000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,MOUSE) 270 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:HARMFUL IF SWALLOWED, INHALED OR
ABSORBED THROUGH SKIN. CAUSES EYE AND SKIN IRRITATION. MATERIAL IS
IRRITATING TO MUCOUS MEMBRANES AND UPPER RESPIRATORY TRACT. MAY
CAUSE ALLERGIC SKIN REACTION. CHRONIC:DAMAGE TO THE LIVER. BLOOD
EFFECTS. POSSIBLE CARCINOGEN. TO THE BEST OF MFR'S KNOWLEDGE, THE
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:CHEMICAL, PHYSICAL AND TOXICOLOGICAL
PROPERTIES HAVE NOT BEEN THOROUGHLY INVESTIGATED. TARGET ORGAN(S):
LIVER, BLOOD.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:IMMED FLUSH W/COPIOUS AMTS OF WATER FOR AT LST 15 MINS.
ASSURE ADEQ FLUSHING BY SEPARATING LIDS W/FINGERS. SKIN:IMMED FLUSH
W/COPIOUS AMTS OF WATER FOR AT LST 15 MINS WHILE REMOVING CONTAM
CLTHG & SHOES. WASH CONTAM CLTHG BEFORE REUSE. INHAL:REMOVE TO
FRESH AIR. IF NOT BRTHG GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE
OXYG. INGEST:WASH OUT MOUTH W/WATER PROVIDED PERS IS CONSCIOUS.
CALL MD.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL POWDER OR
APPROPRIATE FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR NIOSH APPRVD SCBA, RUB
AFTER USE. SWEEP UP, PLACE IN A BAG & HOLD FOR WASTE DISP. AVOID
RAISING DUST. VENT AREA & WASH SPILL SITE AFTER MATL PICKUP IS
COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT & INHALATION. DO NOT GET
IN EYES, ON SKIN, ON CLOTHING. READILY ABSORBED THROUGH SKIN.
TOXIC. POSSIBLE CARCINOGEN. KEEP TIGHTLY CLOSED.
Other Precautions:STORE IN A COOL, DRY PLACE. HARMFUL BY INHALATION, IN
CONTACT W/SKIN & IF SWALLOWED. IRRITATING TO EYES, RESP SYS & SKIN.
MAY CAUSE SENSIT BY SKIN CONT. POSS RISK OF IRREVERSIBLE EFTS. DO
NOT BREATHE DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . WEAR SUITABLE PROTECTIVE CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:>262F,>128C
Appearance and Odor:OFF-WHITE POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS. STRONG ACIDS. STRONG BASES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF: CARBON MONOXIDE,
CARBON DIOXIDE, NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE OR MIX MATERIAL W/COMBUSTIBLE SOLVENT &
BURN IN A CHEMICAL INCINERATOR EQUIPPED W/AFTERBURNER & SCRUBBER.
OBSERVE ALL FEDERAL, STATE & LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:C-553 COOLING TREATMENT
CAGE:0ZUJ2
CAGE:0ZUJ2
============= Composition/Information on Ingredients =============
Ingred Name:POLYMALEIC ACID
CAS:26099-09-2
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES/SKIN: CAUSES IRRITATION.
INGESTION: MAY CAUSE NAUSEA AND DIARRHEA. INHALATION: NOT
CONSIDERED TOXIC. CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NOT KNOWN.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES AND OBTAIN
MEDICAL ATTENTION. SKIN: FLUSH IMMEDIATELY WITH WATER AND OBTAIN
MEDICAL ATTENTION IF IRRITATION PERSISTS. INGESTION: DRINK SMALL
AMOUNTS OF W ATER AND OBTAIN MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER, FOAM, DRY CHEMICAL OR CARBON DIOXIDE FOR
FIRES IN STORAGE AREA.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . KEEP CONTAINER COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:DRIED RESIDUE CAN THERMALLY DECOMPOSE,
GIVING OFF IRRITATING AND TOXIC FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:FOR SMALL SPILLS, FLUSH TO SANITARY SEWER. FOR
LARGE SPILLS, SQUEEGEE AND COLLECT OR VACUUM SPILLAGE AND PLACE IN
CONTAINERS FOR REUSE OF DISPOSAL. FLUSH SPILL AREA WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL PROTECTED LOCATION.
KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:TRIPLE RINSE CONTAINERS BEFORE REUSE OR DISPOSAL.
KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED. USE NIOSH APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST: NOT NORMALLY REQUIRED. MECHANICAL (GENERAL):
IF TLV IS EXCEEDED.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA . PROTECTIVE CLOTHING RECOMMENDED.
Work Hygienic Practices:ALWAYS WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:23.75
Vapor Density:<1
Spec Gravity:1.048
pH:9.39
Evaporation Rate & Reference:1 (H*2O=1)
Solubility in Water:COMPLETE
Appearance and Odor:MUSTY ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:PHOSPHINES, CARBON MONOXIDE, CARBON
DIOXIDE, NO*X MAY FORM.
==================== Disposal Considerations ====================
Waste Disposal Methods:AT APPROVED CHEMICAL WASTE REPROCESSING
FACILITY. DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:POLYISOCYANATE 930G017
CAGE:83574
CAGE:83574
============= Composition/Information on Ingredients =============
Ingred Name:N-BUTYL ACETATE (CERCLA) (VP = 10 MM HG) CERCLA RQ, 5000
LBS.
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 10.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:150 PPM/STEL 200
ACGIH TLV:150 PPM/STEL 200
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE (SARA 313) (CERCLA) (VP = 70 MM HG)
CERCLA RQ, 5000 LBS.
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 10.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM/STEL 300
ACGIH TLV:200 PPM/STEL 300
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2,4-PENTANEDIONE (VP = 7.0 MM HG)
CAS:123-54-6
Fraction by Wt: <5.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHYL-3-ETHOXYPROPIONATE (VP = 1.1 MM HG)
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: 10.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TOLUENE (SARA 313) (CERCLA) (VP = 23.0 MM HG) CERCLA RQ,
1000 LBS.
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <5.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM/STEL 150
ACGIH TLV:50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:AROMATIC HYDROCARBON SOLVENT NAPHTHA (PETROLEUM), LIGHT
AROMATIC.
CAS:64742-95-6
Fraction by Wt: 5.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TRIMER HDI (VP = 0 MM HG)
CAS:3779-63-3
Fraction by Wt: 50.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:AROMATIC SOLVENT (VP = 0 MM HG)
CAS:64742-94-5
RTECS #:WF3100000
Fraction by Wt: <5.0%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:INHAL RAT LC50 2.18/LITER 4 HOUR
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: IRRIT, BURNING, TEARING,
REDDENING, CORNEAL INJURY, CONJUNCTIVA SWELLING. SKIN: DRYING,
CRACKING, REDNESS, BURNING, DERMATITIS, DEFATTING. INHAL: DIZZY,
DROWSY, FATIGUE, COUGHING, CHEST PAINS, TH ROAT/RESP/MUCOUS
MEMBRANE IRRIT, HEADACHE, ANESTHETIC, CNS EFFECTS, NAUSEA,
UNCONSCIOUS, WEAKNESS, LIVER/KIDNEY DAMAGE.
Effects of Overexposure:INGEST: DROWSY, DIZZY, NAUSEA, DIARRHEA,
ABDOMENAL DISCOMFORT, DISTURBANCE IN MEMORY/THINKING
ABILITY/EMOTIONS/COORDINATION, CNS DEPRESSION, UNCONSCIOUS.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/WATER FOR 15 MINUTES. SKIN: WASH W/SOAP & WATER.
DONT USE SOLVENTS. REMOVE CONTAM CLOTHES, WASH BEFORE REUSE. INHAL:
REMOVE TO FRESH AIR. ARTIF RESP/CPR IF NEEDED. INGEST: CALL DR. IN
ALL CASES, GET IMMED MED AID.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:56.0F,13.3C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. COOL
CONTAINERS W/WATER. FOG NOZZLES PREFERRED. USE SCBA AND PROTECTIVE
CLOTHES. CLOSED CONTAINERS EXPLODE IN HIGH HEAT.
Unusual Fire/Explosion Hazard:VAPORS COLLECT IN POORLY VENTED OR
CONFINED AREAS. VAPORS FORM EXPLOSIVE MIXTURES W/AIR. VAPORS TRAVEL
TO IGNITS AND FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:PROTECT FROM IGNITS. USE AIR SUPPLIED
RESPIRATOR. FOR UNVENTED SPILLS. COVER W/ABSORBENT. ADD DECOMP
SOLUTION* ALLOW TO REACT 10 MINUTES. COLLECT IN CONTAINER. ADD
ADDITIONAL DECOMP SOLUTION* KEEP LOO SELY COVERED FOR 48 HOURS.
Neutralizing Agent:*DECOMP SOLUTION: 5% CONCENTRATED AMMONIA, 2%
DETERGENT, 93% WATER
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. ISOLATE
FROM IGNITS. DONT STORE >120F.
Other Precautions:EMPTY DRUMS MAY CONTAIN EXPLOSIVE VAPORS. DONT CUT,
PUNCTUREOR WELD ON OR NEAR DRUM. DURING A FIRE, IRRITATING AND
TOXIC GASES AND AEROSOLS FROM DECOMPOSITION/COMBUSTION PRODUCTS MAY
BE PRESENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN SPRAYING OR APPLYING IN CIRCUMSTANCES
LIKELY TO PRODUCE AIRBORNE LEVELS OF HAZARDOUS INGREDIENTS IN
EXCESS OF TLV, USE ORGANIC VAPOR CARTRIDGE OR AIR SUPPLIED
RESPIRATOR.
Ventilation:GENERAL VENTILATION TO MAINTAIN VAPORS BELOW PEL AND TLV.
Other Protective Equipment:AVOID SKIN CONTACT BY USE OF OTHER
PROTECTIVE EQUIPMENT. DURING SPRAY APPLICATION COMPLETE SKIN
PROTECTION REQUIRED.
Work Hygienic Practices:SAFETY SHOWER, EYE BATH AND WASHING FACILITIES.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:175 TO 355F
Vapor Density:>AIR
Spec Gravity:1.004
VOC Pounds/Gallon:493
Evaporation Rate & Reference:NA
Appearance and Odor:CLEAR LIQUID, SOLVENT ODOR.
Percent Volatiles by Volume:43.8
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONTACT W/WATER, ALCOHOLS AND AMINES.
Hazardous Decomposition Products:CARBON DIOXIDES AND CARBON MONOXIDE.
MAY ALSO INCLUDE OXIDES OF NITROGEN AND TRACES OF HCN AND
ISOCYANATE MONOMER.
==================== Disposal Considerations ====================
Waste Disposal Methods:WHEN DISPOSING OF THIS MATERIAL, INSURE THAT IT
IS PACKAGED, STORED, TRANSPORTED AND OTHERWISE PACKAGED IN
ACCORDANCE W/FEDERAL, STATE AND LOCAL REGULATIONS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CADNICA 1.2V, NICKEL CADMIUM BATTERY
CAGE:00JU0
CAGE:0A272
CAGE:00JU0
============= Composition/Information on Ingredients =============
Ingred Name:CADMIUM (SARA 313) (CERCLA)
CAS:7440-43-9
RTECS #:EU9800000
Fraction by Wt: 11-26%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 MG/M3 DUST; Z-2
ACGIH TLV:0.01 MG/M3 DUST;9596
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:CADMIUM HYDROXIDE
CAS:21041-95-2
Fraction by Wt: 11-26%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.05 MG CD/M3
ACGIH TLV:0.05 MG CD/M3
Ingred Name:NICKEL (SARA 313) (CERCLA)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 8-17%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9596
Ingred Name:NICKEL HYDROXIDE (SARA 313) (CERCLA)
CAS:12054-48-7
RTECS #:QR7040000
Fraction by Wt: 5-12%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG(NI)/M3
ACGIH TLV:0.1 MG(NI)/M3; 9596
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:POTASSIUM HYDROXIDE (CERCLA)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: <3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:BATT CELL SHOULDNT BE OPN/EXPO TO HEAT
BECAUSE EXPO TO INGREDS CONTAINED W/IN COULD BE HARMFUL UNDER SOME
CIRCUMSTANCES.BATT BREACH-INHAL:CD DUST/FUME EMITTED-THRAOT
DRYNESS,RESP IRRIT,HEAD,NAU,VOMIT, CHEST PAIN,EXT
RESTLESSNESS,IRRITABILITY,PNEUITIS,BRONCHOPNEU,HI CONC
DEATH.INGEST:LOCALIZED BURNS,INCR (SUPPLEMENTAL)
Explanation of Carcinogenicity:PER MSDS:NTP-CD,NI CARC;EPA-CD
B1;IARC-CD 2A;ACGIH-CD A2.
Effects of
Overexposure:HEALTH:SALIVATION,CHOKING,NAU,PERSISTENT,VOMIT,DIARR,A
BD PAIN,ANEMIA,TENEAMUS,KID DISFUNCTION.NO SKIN
ABSORPTION.SKIN:CHEM BURNS,DERM IN SENSITIVE INDIVIDUALS.EYE:SEVERE
IRRIT,CHEM BURNS. REP OVEREXPO TO CD LUNG CANC,LUNG/KID/LIVER
DISFUNCTION,SKELETAL DISEASE,REPRD TOXICITY.CHRONIC OVEREXPO TO NI
CANC,DERM.
Medical Cond Aggravated by Exposure:KNOWLEDGE OF AVAI TOXICOLOGY INFO &
PHYS & CHEM PROPERTIES OF MATL SUGGESTS THAT OVEREXPO IN UNLIKELY
TO AGGRAVATE EXISTING MED CONDITIONS.
======================= First Aid Measures =======================
First Aid:INGEST:DONT INDUCE VOMIT.SEEK MED ATTN IMMED.SKIN:OPN BATT
CONTACT SKIN IMMED LFUSH W/H2O FOR @LEAST 15MINS.INHAL:REMOVE IMMED
TO FRESH AIR.SEEK MED ATTN.EYE:OPN BATT CONTACT EYES IMMED FLUSH
EYES W/H 2O CONT FOR @LEAST 15MINS.SEEK MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:NA
Autoignition Temp:Autoignition Temp Text:NP
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:ANY CLASS OF EXTINGUISHING MEDIUM MAY BE USED ON
BATTERIES OR THEIR PACKING MATERIAL.
Fire Fighting Procedures:EXPO TO TEMP OF >212F CAN CAUSE EVAPO OF
LIQ(KOH ELECTRO)RESULT IN CELL RUPTURE.POT FOR EXPO TO CD FUMES
DUING FIRE;USE SCBA.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:SPILL/LEAK UNLIKELY-CELLS CONTAIN IN
HERMETICALLY SEALED CASE.CASE BREACH DON PROT CLOTH IMPERV TO
CAUSTIC MATLS.ABSORB/PACK RESIDUE IN INERT MATL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL PLACE,PREVENT CONDENS ON
CELL/BATT TERMINALS.ELEV TEMPS RESULT IN RED BATT LIFE.OPTIMUM
STORAGE TEMP:31F-95F.DONT SHAKE BATT IN BULK CNT
Other Precautions:CONCEN OF INGREDS VARY DEPENDING ON STATE OF CHARGE
OR DISCHARGE.ENCAP/SEAL REQMT & SOLDER/WELD ALL SANYO FOR HAZ
PRECAUT/LIMITATIONS.DONT INCINERATE/SUBJ TO TEMP >212F-CAN VAPORZIE
LIQ CAUSE CELL RUP TURE.INCINERATION MAY CAUSE CD EMISSIONS
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER NORMAL USE.
Ventilation:NOT REQUIRED UNDER NORMAL USE.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:BATT DESIGNED FOR RECHARGING.CHARGE BATT BEF
USE.OBSERVE SPEC CHARGE RATE.
Supplemental Safety and Health
DURING NORMAL USE HAZ MATLS FULLY CONTAINED INSIDE BATT CELL.EXPO TO
FIRE/EXPLO/EXTREME ABSUE/MISUSE/IMPROPER DISPO RESULT IN BREACHING
BATT CELL CASE HAZ MATLS MAY BE RELEASED.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NP
Melt/Freeze Pt:M.P/F.P Text:NP
Decomp Temp:Decomp Text:NP
Vapor Pres:NP
Vapor Density:NP
Spec Gravity:NP
pH:NP
Viscosity:NP
Evaporation Rate & Reference:NP
Solubility in Water:NP
Appearance and Odor:MFG ARTICEL PER 29CFR1910.1200.BATT CELL IN
HERMETICALLY-SEALED CASE.
Percent Volatiles by Volume:NP
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BATT CELL IN ENCASED IN NON-REACTIVE CNTNR;BREACHED-AVOID INTERNAL BATT
CONTACT W/ACIDS,ALDEHYDES,CARBAMATE CMPDS.
Stability Condition to Avoid:HEAT,OPN FLAMES,SPARKS,MOISTURE.RE.AVOID
PROL SHORT CIRCUIT-HEAT BURN SKIN,RUPTURE BATT CASE.
Hazardous Decomposition Products:OXIDES OF CADMIUM & NICKEL.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPO OF AS HAZ WASTE IAW APPLIC STATE/FED
REGS.RESULTANT SPILL RESIDUES MAY BE CHARACTER AS
D002(CAUSTIC),D005(CD)PER RCRA.RETURN TO SANYO FOR RECYCLE.CALL
SANYO REP FOR INFO ON EARTHSAVER 2001 RECYC L PROGRAM.BATT HNDLG
IAW ALL STATE/FED LAWS/REGS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:RUST NIX BLACK (SOLVENT BASED)
CAGE:4J296
CAGE:4J296
============= Composition/Information on Ingredients =============
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 5.00%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:VM&P NAPHTHA; (MINERAL SPIRITS)
CAS:64742-48-9
Fraction by Wt: 55%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ALKYD RESIN
CAS:67762-07-6
Fraction by Wt: 40%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE:MAY RSLT IN SLIGHT IRRIT.
INHAL:OVEREXP CAN LEAD TO CNS DEPRESS PRDCING SUCH EFTS AS HDCH,
DIZZ, NAUS & LOSS OF CONSCIOUSNESS. INGEST:CAN CAUSE GI IRRIT,
VOMIT & DIARR. ASPIR OF MATL INTO LU NGS CAN CAUSE CHEM PNEUM WHICH
CAN BE FATAL. CHRONIC:EYES:PRLNGD & RPTD CONT MAY BE MORE IRRIT.
SKIN: (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:PRLNGD & RPTD LIQ CONT CAN CAUSE
DEFAT & DRYING WHICH MAY RSLT IN IRRIT & DERM. INHAL:HIGH
CONCS/PRLNGD EXPOS TO LOWER CONCS MAY BE SLIGHTLY IRRIT TO MUC
MEMBS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER FOR AT LST 15 MIN WHILE HOLDING EYELIDS
OPEN. GET MED ATTN. SKIN:WASH W/SOAP & WATER. REMOVE CONTAM CLTHG &
SHOES. DO NOT REUSE UNTIL CLEANED. IF PERSISTENT IRRIT OCCURS, GET
MED AT TN. INHAL:REMOVE TO FRESH AIR & PROVIDEOXYG IF BRTHG IS
DFCLT. GIVE ARTF RESP IF NOT BRTHG. GET MED ATTN. INGEST:DO NOT
INDUCE VOMIT!!!
===================== Fire Fighting Measures =====================
Flash Point:104F,40C
Lower Limits:0.8%
Upper Limits:5.0%
Extinguishing Media:WATER FOG, DRY CHEMICAL, CARBON DIOXIDE, FOAM.
Fire Fighting Procedures:EVAC AREA OF UNPROT PERS. WEAR NIOSH/MSHA
APPRVD SCBA & FULL PROT EQUIP COOL FIRE-EXPOSED CNTNRS W/WATER.
Unusual Fire/Explosion Hazard:VAPORS ARE HVR/AIR & MAY ACCUM IN LOW
AREAS/AREAS INADEQUATELY VENT. VAPS MAY ALSO TRAVEL ALONG GROUND TO
BE IGNITED AT LOCATIONS DIST FROM HNDLG SITE.
================== Accidental Release Measures ==================
Spill Release Procedures:WARNING! FLAM. ELIM ALL IGNIT SOURCES. HNDLG
EQUIP MUST BE GROUNDED TO PVNT SPKING. LG SPILLS:EVAC HAZ AREA OF
UNPROT PERS. WEAR APPROP NIOSH/MSHA APPRVD RESP & PROT CLTHG. DIKE
& CNTN.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPKS & OPEN
FLAME. KEEP CNTNRS TIGHTLY CLSD. STORE AWAY FROM STRONG OXIDIZING
AGENTS IN DRY PLACE W/ADEQ EXPLO-PROOF VENT.
Other Precautions:GROUND EQUIP TO PVNT ACCUM OF STATIC CHARGE. IF
POURING/TRANSFERRING MATLS, CNTNRS MUST BE BONDED & GROUNDED. DO
NOT WELD, HEAT/DRILL ON/NEAR CNTNR; EVEN EMPTIED CNTNRS CAN CNTN
EXPLO VAPS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOS MAY/DOES EXCEED OCCUP EXPOS LIMS USE
NIOSH/MSHA APPRVD RESP TO PVNT OVEREXP. PROVIDE NIOSH/MSHA APPRVD
RESP PROT AGAINST SMK & FUMES GENERATED DURING BURNING/DUSTS
GENERATED DURING REMOVAL OF DRY COATINGS.
Ventilation:LOC EXHST:SUFFICIENT VENT, IN VOL & PATTERN, SHOULD BE
PROVIDED TO KEEP AIR CONTAMS BELOW CURRENT APPLIC OSHA (SUP DAT)
Other Protective Equipment:APPRVD EYE WASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA . PROT CLTH AS REQUIRED TO PREVENT SKIN CONT.
Work Hygienic Practices:WASH W/SOAP & WATER BEFORE EATING, DRINKING,
SMKING/USING TOILET FACILITIES. LAUNDER CONTAM CLTHG BEFORE REUSE.
Supplemental Safety and Health
OR REPEATED CONTACT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>240F,>116C
Vapor Pres:6.0
Vapor Density:HEAVIER
Evaporation Rate & Reference:SLOWER
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK LIQUID, HYDROCARBON ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:AVOID HEAT, SPARKS AND OPEN FLAME.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . PLACE CONTAMINATED MATERIAL IN SUITABLE CONTAINERS
FOR DISPOSAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MACHINE COLORANT MC-K CHROMIUM GREEN OXIDE, 790-120
CAGE:ENGEL
CAGE:ENGEL
GROUP
CAGE:34316
============= Composition/Information on Ingredients =============
Ingred Name:DIETHYLENE GLYCOL
CAS:111-46-6
RTECS #:ID5950000
Fraction by Wt: 14%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CHROMIUM (III) OXIDE (2:3); (CHROMIUM (3+) OXIDE)
CAS:1308-38-9
RTECS #:GB6475000
Fraction by Wt: 45%
OSHA PEL:1 MG/M3 (MFR)
ACGIH TLV:0.5 MG/M3 (MFR)
Ingred Name:SURFACTANT(S)
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUNDS: 337 G/L
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: IRRIT & MAY CAUSE BURNS. SKIN:
PRLNG/RPTD CNTCT MAY CAUSE IRRIT. EXCESS EXPOS MAY RSLT IN
ABSORPTION OF TOX AMTS. INHAL: AT ROOM TEMPS, EXPOS TO VAP/MISTS
UNLIKELY. HIGHER TEMPS MAY GENERATE VAP S/MISTS SUFFICIENT TO CAUSE
DROW & HDCH. INGEST: LG AMTS OF DIETHYLENE GLYCOL MAY RSLT IN TOX
EFT ON (EFTS OF OVEREXP)
Explanation of Carcinogenicity:CHROMIUM (III) OXIDE (2:3): NTP 6TH
ANNUAL REPORT ON CARCINOGENS, 1991: KNOWN TO BE CARCINOGENIC.
Effects of Overexposure:HLTH HAZ: CNS, GI TRACT, KIDNEY & LIVER. SINGLE
LG AMT MAY CAUSE SEV DMG/BE FATAL. NOTE: LAB ANIMAL STUDIES
INDICATE THAT GLYCOL ETHERS MAY CAUSE REPRO EFTS. CHRONIC: EXCESS
EXPOS BY ANY ROUTE MAY CAU SE DEGENERATION OF KIDNEY & TO LESSER
EXTENT, LIVER. IN ANIMAL STUDIES, FORMATION OF BLADDER STONES &
(SUPDAT)
Medical Cond Aggravated by Exposure:MAY ADVERSELY AFFECT EXISTING
MEDICAL CONDITIONS SUCH AS RENAL, HEPATIC & NEUROLOGICAL DISORDERS.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/PLENTY WATER FOR AT LEAST 15 MIN.
CALL MD. SKIN: FLUSH W/PLENTY WATER. IF IRRITATION PERSISTS, CALL
MD. INHALATION: REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT,
GIVE OXYGE N. CALL MD. INGESTION: IMMEDIATELY GIVE2 GLASSES WATER &
CALL MD, HOSPITAL EMERGENCY ROOM/POISON CONTROL CENTER FOR WAY TO
INDUCE VOMITING. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE WATER, CARBON DIOXIDE OR FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT A FIRE OR EXPLOSION HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILLAGE, SOAK UP W/INERT ABSORB &
SCOOP INTO CNTNR FOR DISP. NOTIFICATION OF NRC MAY BE REQD. REFER
TO EPA, DOT & APPLIC STATE & LOCAL REGS FOR CURRENT RESPONSE INFO.
RECOM EACH USER ESTABLIS H SPILL PREVENTION, CTL & COUNTERMEASURE
(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM FOOD AND FEED PRODUCTS.
KEEP CONTAINER CLOSED. PROTECT FROM FREEZING.
Other Precautions:AVOID BREATHING MIST. AVOID CONTACT WITH EYES, SKIN
AND CLOTHING. USE ONLY WITH ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR AS NECESSARY.
Ventilation:GENERAL; LOCAL EXHAUST AS NECESSARY TO CONTROL VAPORS
AND/OR MISTS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
EFTS OF OVEREXP: SECONDARY BLADDER CANCER HAS BEEN OBSERVED. SPILL
PROC: PLAN (SPCC). IN EVENT OF ACCIDENTAL RELS, ABOVE PROC SHOULD
BE FOLLOWED. ADDNLY PROPER EXPOS CTLS & PERSONAL PROT EQUIP SHOULD
BE USED & MATL DISPOSED OF I/A/W APPLICREGS.
================== Physical/Chemical Properties ==================
Vapor Pres:<17.5 @20C
Spec Gravity:2.29 (H*2O=1)
pH:7.8
Evaporation Rate & Reference:MUCH <1 (BUTYL ACETATE=1)
Solubility in Water:32.8%
Appearance and Odor:GREEN LIQUID; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE EXPECTED.
Stability Condition to Avoid:NONE EXPECTED.
Hazardous Decomposition Products:NONE EXPECTED.
==================== Disposal Considerations ====================
Waste Disposal Methods:FED, STATE & LOC DISP LAWS & REGS WILL DETERM
PROPER WASTE DISP/RECYCLING/RECLAMATION PROC. WASTE MATLS SHOULD BE
REVIEWED TO DETERM APPLIC HAZ (TESTING MAY BE NEC). DISP REQS
DEPENDENT ON HAZ CLASSIF ICATION & WILL VARY BY LOCATION & TYPE OF
DISP.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CA 15-3 CALIBRATOR B,9C08D
Resp. Party Other MSDS Num.:H
CAGE:33110
CAGE:33110
============= Composition/Information on Ingredients =============
Ingred Name:TRIS(HYDROXYMETHYL)AMINOMETHANE; (TRIS HYDROXYMETHYL
AMINOMETHANE)
CAS:77-86-1
RTECS #:TY2900000
= Wt:1.1
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
= Wt:92.2
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:SODIUM AZIDE
CAS:26628-22-8
RTECS #:VY8050000
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:C0.29 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE TOXICOLOGICAL INFORMATION.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ROUTES OF EXPOSURE FOR BLOODBORNE
PATHOGENS: NON-INTACT SKIN, MUCOUS MEMBRANES, PARENTERAL CONTACT.
THIS PRODUCT CONTAINS HUMAN SOURCED AND/OR POTENTIALLY INFECTIOUS
COMPONENTS.
Explanation of Carcinogenicity:THIS PRODUCT DOES NOT CONTAIN
CARCINOGENS LISTED BY IARC, NTP, OSHA OR ACGIH.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PREEXISTING RENAL AILMENTS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM SOURCE OF EXPOSURE. IF SIGNS OF
TOXICITY OCCUR, SEEK MEDICAL ATTENTION. PROVIDE
SYMPTOMATIC/SUPPORTIVE CARE AS NEEDED. SKIN: REMOVE FROM SOURCE OF
EXPOSURE. WASH AFFECTED AREA WITH SOAP AND WATER. SEEK MEDICAL
ATTENTION AND APPROPRIATE FOLLOW-UP. EYES: FLUSH WITH COPIOUS
AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. SEEK MEDICAL ATTENTION
AND APPROPRIATE FOLLOW-UP. INGESTION: R INSE MOUTH WITH WATER. SEEK
MEDICAL ATTENTION AND APPROPRIATE FOLLOW-UP. INFORMATION FOR
DOCTOR: SEE HEALTH HAZARDS SECTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, EXTINGUISHING POWDER OR WATER
SPRAY. FIGHT LARGER FIRES WITH WATER SPRAY OR ALCOHOL RESISTANT
FOAM.
Fire Fighting Procedures:REPIRATORY PROTECTION NOT NORMALLY REQUIRED
UNLESS EXPOSURE LIMITS FOR COMPONENTS ARE EXCEEDED. WEAR NIOSH
APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:PRODUCT IS NOT SELFIGNITING. PRODUCT DOES
NOT PRESENT AN EXPLOSION HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:NIOSH APPRVD RESP PROT SHOULD BE WORN IF EXPOS
LIMS CAN BE EXCEEDED. HANDLE AS POTENTIALLY INFECTIOUS. PVNT LIQ &
VAP FROM ENTERING INTO SEWAGE SYS, WORKPITS & CELLARS. CONTAIN
SPILL W/APPROP ABSORB M ATL. ABSORB W/LIQ-BINDING MATL (SAND,
DIATOMITE, ACID BINDERS, UNIVERSAL BINDERS, SAWDUST). WEAR PROT
EQUIP. CLEAN AREA W/DETERGENT. APPLY SUITABLE DISINFECTANT. NO
DANGEROUS SUBSTANCES ARE RELEASED.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE AS A POTENTIALLY INFECTIOUS
MATERIAL. NO SPECIAL MEASURES REQUIRED ABOUT PROTECTION AGAINST
EXPLOSIONS AND FIRES. NO SPECIAL REQUIREMENTS TO BE MET BY
STOREROOMS AND RECEPTACLES. DO NOT STORE T OGETHER WITH ACIDS.
Other Precautions:PROTECT FROM HEAT AND DIRECT SUNLIGHT. STORAGE CLASS:
NOT APPLICABLE. CLASS ACCORDING TO REGULATION ON FLAMMABLE LIQUIDS:
NOT APPLICABLE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NECESSARY IF ROOM IS WELL-VENTILATED. THE
APPROPRIATE RESPIRATORY PROTECTION SHOULD BE USED IF AIRBORNE
CHEMICAL CONCENTRATION EXCEEDS THE EXPOSURE LIMITS LISTED. WEAR
NIOSH APPROVED RESPIRATOR AP PROPRIATE FOR EXPOSURE OF CONCERN .
MATERIAL IS ANTICIPATED.
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . WEAR LABORATORY COAT OR PROTECTIVE GARB WHEN
WORKING WITH THE MATERIAL.
Work Hygienic Practices:KEEP AWAY FROM FOODSTUFFS, BEVERAGES AND FEED.
WASH HANDS BEFORE BREAKS AND AT THE END OF WORK. THE USUAL
BIOSAFETY PRACTICES FOR HANDLING POTENTIALLY INFECTIOUS MATERIALS
SHOULD BE FOLLOWED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:=100.C, 212.F
Melt/Freeze Pt:M.P/F.P Text:NOT DETERMINED
Vapor Pres:23.0 HPA @ 20C
pH:7.4 @ 20C
Solubility in Water:FULLY MISCIBLE
Appearance and Odor:COLORLESS LIQUID; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTIONS WITH HEAVY METALS MAY FORM EXPLOSIVE SUBSTANCES. CONTACT WITH
ACIDS MAY RELEASE TOXIC GAS (I.E., HYDROGEN AZIDE HN*3).
Stability Condition to Avoid:NO DECOMPOSITION IF USED ACCORDING TO
SPECIFICATIONS.
Hazardous Decomposition Products:NO DANGEROUS DECOMPOSITION PRODUCTS
KNOWN.
=================== Toxicological Information===================
Toxicological Information:ACUTE TOXICITY: LD/LC50 VALUES FOR HAZARDOUS
INGREDIENTS PER OSHA CRITERIA: COMPONENTS (100% PURE SUBSTANCE/S):
77-86-1 TRIS HYDROXYMETHYL AMINOMETHANE: ORAL: LD50: 590-1780 MG/KG
(RAT); LDLO = 1000 M G/KG IN RABBITS. PRIMARY IRRITANT EFFECTS: ON
THE SKIN: NO IRRITANT EFFECTS; ON THE EYE: NO IRRITANT EFFECTS;
SENSITIZATION: NO SENSITIZING EFFECTS KNOWN; TARGET ORGANS/SYSTEMS:
KIDNEYS.
===================== Ecological Information =====================
Ecological:GENERAL NOTES: DO NOT ALLOW UNDILUTED PRODUCT OR LARGE
QUANTITIES OF IT TO REACH GROUND WATER, WATER COURSES OR SEWAGE
SYSTEM.
==================== Disposal Considerations ====================
Waste Disposal Methods:RECOMMENDATION: DISPOSE IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS. UNCLEANED PACKAGINGS:
RECOMMENDATION: DISPOSE IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS. RECOMMENDED CLEA NSING AGENT: WATER, IF NECESSARY WITH
CLEANSING AGENTS.
=================== MSDS Transport Information ===================
Transport Information:DOT REGULATIONS: REMARKS: NOT REGULATED FOR
TRANSPORTATION. LAND TRANSPORT ADR/RID (CROSS-BORDER): REMARKS: NOT
REGULATED FOR TRANSPORTATION; MARINE POLLUTANT: NO; REMARKS: NOT
REGULATED FOR TRANSPORT ATION. ICAO/IATA: REMARKS: NOT REGULATED
FOR TRANSPORTATION.
===================== Regulatory Information =====================
SARA Title III Information:SARA (SUPERFUND AMENDMENTS AND
REAUTHORIZATION ACT OF 1986 - USA): SECTION 302/304 (40 CFR 355.30
/ 40 CFR 355.40): 26628-22-8 SODIUM AZIDE; SECTION 313 (40 CFR
372.65): 26628-22-8 SODIUM AZIDE.
Federal Regulatory Information:MARKINGS ACCORDING TO EUROPEAN
GUIDELINES: THE PRODUCT HAS BEEN CLASSIFIED & LABELLED IN
ACCORDANCE WITH APPLICABLE EUROPEAN COMMUNITY (EC) DIRECTIVES. CODE
LETTER & HAZARD DESIGNATION OF PRODUCT: XN. HAZARD-DETERMINING
SUBSTANCE/S OF LABELLING: SODIUM AZIDE. RISK PHRASES: 22 HARMFUL IF
SWALLOWED; 32 CONTACT WITH ACIDS LIBERATES VERY TOXIC GAS. SAFETY
PHRASES: 2 KEEP OUT OF THE REACH OF CHILDREN; 13 KEEP AWAY FROM
FOOD, DRINK & ANIMAL FEEDINGSTUFFS; 36 WEAR SUITABLE PROTECTIVE
CLOTHING; 46 IF SW ALLOWED, SEEK MEDICAL ADVICE IMMEDIATELY & SHOW
THIS CONTAINER OR LABEL. CLASSIFICATION/WARNING ACCORDING TO
WORKSAFE AUSTRALIA: HAZARDOUS.
State Regulatory Information:CALIFORNIA PROPOSITION 65 (USA): CHEMICALS
KNOWN TO CAUSE CANCER OR REPRODUCTIVE TOXICITY: THE PRODUCT DOES
NOT CONTAIN LISTED SUBSTANCES.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:GLASS-PLUS
CAGE:FO654
CAGE:FO654
CAGE:45255
============= Composition/Information on Ingredients =============
Ingred Name:FORMALDEHYDE, FORMALIN (SUSPECTED HUMAN CARCINOGEN BY IARC;
ACGIH; SUSPECTED CARCINOGEN BY NTP; IARC - GROUP 2A) *97-2*
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: <0.1%
ACGIH TLV:0.37 MG/CUM IC (2A)
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:GLASS OXIDE, FIBER GLASS WOOL, LEAD BOROSILICATE GLASS
ENAMEL FLUX
CAS:65997-17-3
Fraction by Wt: 85-96%
Ingred Name:PHENOL, UREA, FORMALDEHYDE RESIN
CAS:25104-55-6
Fraction by Wt: 4-15%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 500-800 MG/KG (SEE SUPP)
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:FIBER GLASS WOOL IS A MECHANICAL
IRRITANT & MAY CAUSE TEMPORARY IRRITATION OF THE RESPIRATORY TRACT,
SKIN & EYES.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION.
Medical Cond Aggravated by Exposure:CHRONIC RESPIRATORY/SKIN
CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED.
EYES: FLUSH W/RUNNING WATER FOR 15 MINS. SKIN: WASH W/MILD SOAP &
RUNNING WATER. USE A WASH CLOTH TO HELP REMOVE FIBERS. DON'T
RUB/SCRATCH A REAS. RUBBING/SCRATCHING MAY FORCE FIBERS INTO SKIN.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:WATER, FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:USE SELF CONTAINED BREATHING APPARATUS IN A
SUSTAINED FIRE.
Unusual Fire/Explosion Hazard:VINYL FACED PRODUCTS WILL RELEASE
HYDROGEN CHLORIDE IN A FIRE. EVACUATE BUILDING IMMEDIATELY IF THIS
OCCURS.
================== Accidental Release Measures ==================
Spill Release Procedures:LAND: SCOOP UP/VACUUM MATERIAL INTO A SUITABLE
CONTAINER. WATER: MATERIAL WILL SINK/DISPERSE ALONG BOTTOM OF
WATERWAYS/PONDS. IT CAN'T EASILY BE REMOVED AFTER ITS WATERBORNE.
AIR: MATERIAL WILL SETTLE OUT OF THE AIR, IT CAN BE SCOOPED
UP/VACUUMED.
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL STORAGE/HANDLING PROCEDURES
ARE REQUIRED FOR THIS MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE 3M MODEL 8710 FOR INSTALLING LOOSEFILL, IN
ANY POORLY VENTILATED SPACE, FABRICATION INVOLVING POWER TOOLS/ANY
DUSTY ENVIRONMENT.
Ventilation:GENERAL DILUTION/LOCAL EXHAUST TO MAINTAIN EXPOSURE <
LIMITS. DUST COLLECTION SYSTEMS ARE REQUIRED IN USING POWER TOOLS.
Other Protective Equipment:LOOSE FITTING LONG SLEEVED SHIRT, LONG
PANTS.
Supplemental Safety and Health
APPEARANCE CONT'D: SOME PRODUCTS HAVE A VINYL BROWN PAPER,
FOIL/POLYPROPYLENE FACING. ORAL LD50 INFORMATION IS FOR
FORMALDEHYDE.
================== Physical/Chemical Properties ==================
Solubility in Water:INSOLUBLE
Appearance and Odor:PINK, YELLOW/TAN FIBROUS MATERIAL W/FAINT RESIN
ODOR.(SEE SUPP)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CO, CO2, AMMONIA, WATER, HYDROGEN
CHLORIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1,2-DINITROGLYCERIN IN ACETONITRILE
CAGE:GO711
CAGE:GO711
CAGE:29913
============= Composition/Information on Ingredients =============
Ingred Name:1,2-DINITROGLYCERIN
CAS:621-65-8
RTECS #:MA9487000
Fraction by Wt: 0.1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACETONITRILE (SARA 313) (CERCLA). BP: 180F,82C SPEC GRAV:
0.783 (H*2O = 1) VP: 100 @ 27C MP: -49F,-45C (ING 3)
CAS:75-05-8
RTECS #:AL7700000
Fraction by Wt: 99.9%
OSHA PEL:40 PPM
ACGIH TLV:40 PPM/60 STEL; 9495
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ING 2: VAP DENS: 1.42 EVAP RATE: 5.79 (BUTYL ACETATE = 1)
SOL IN H*2O: MISCIBLE APPEAR/ODOR: CLEAR, COLORLESS, (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3: LIQUID, ETHEREAL ODOR.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPOS TO ACETONITRILE MAY RESULT IN
CONVUL, COMA, UNCONSCIOUSNESS & DEATH. ACETONITRILE IS A
LACRIMATOR. TOXICOLOGICAL PROPERTIES OF 1,2-DINITROGLYCERIN HAVE
NOT BEEN FULLY INVESTIGATED. IT SHOULD BE ASSUMED TO HAVE TOXIC
EFTS &, THEREFORE, PROCS APPROP FOR SAFE HANDLING OF HAZARDOUS
CHEMICALS SHOULD BE FOLLOWED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:EXPOS TO ACETONITRILE MAY CAUSE EYE & SKIN
IRRIT, NAUS, VOMIT, CONSTRICTION OF THROAT, CONFUSN, HDCH,
TACHYCARDIA, DYSPNEA, CHEST PAIN, COUGH, BILE-/BLOOD-STAINED
EMESIS, TACHYPNEA, CYANOSIS, LACRIMAT ION, CONVL, COMA, DIARR,
ABDOM PAIN, WEAK, FATIGUE, FLUSHING OF FACE, TIGHTNESS OF CHEST,
DFCLT BRTHG, RESP (SUPDAT)
Medical Cond Aggravated by Exposure:NOT APPLICABLE.
======================= First Aid Measures =======================
First Aid:INGEST: GIVE VICTIM LARGE QTIES OF LIQUID & TRANSPORT TO MED
FACILITY. IN CASE OF EXTERNAL EXPOS, WASH AFFECTED AREAS W/LARGE
AMTS OF WATER & TRANSPORT TO A MED FACILITY. INHAL: IF BREATHING IS
DISTUR BED, GIVE ARTF RESP WHILE TRANSPORTING TO A MED FACILITY.
EYES: IMMED FLUSH W/POTABLE WATER FOR A MIN OF 15 MIN, SEEK
ASSISTANCE FROM MD . SKIN: FLUSH W/COPIOUS AMTS OF WATER. CALL MD .
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:42.0F,5.6C
Lower Limits:4.4%
Upper Limits:16.0%
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE OR HALON EXTINGUISHER.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:THE VAPOR IS HEAVIER THAN AIR AND MAY
TRAVEL TO A SOURCE OF IGNITION AND FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. USE ABSORBENT
PAPER TO PICK UP ALL SPILLED MATERIAL. IF NECESSARY, SOAK ABSORBENT
PAPER IN AN APPROPRIATE SOLVENT SUCH AS TOLUENE OR ALCOHOL TO PICK
UP REMAINING TRACES .
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:FREEZER. PROTECT FROM LIGHT AND
MOISTURE. DO NOT ALLOW SOLVENT TO EVAPORATE TO DRYNESS.
Other Precautions:ONLY EXPERIENCED PERSONNEL SHOULD BE ALLOWED TO
HANDLE THIS MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID INHALATION OF VAPORS. NIOSH APPROVED
CARTRIDGE TYPE RESPIRATOR WITH NIOSH APPROVED ORGANIC VAPOR
CARTRIDGES RECOMMENDED.
Ventilation:LOCAL EXHAUST: USE WITH FORCED VENTILATION. GENERAL
MECHANICAL: NORMAL LABORATORY AIR EXCHANGE.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . LAB COAT, APRON, OR TYVEK SUIT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MATLS TO AVOID: PERCHLORATES, NITRATING AGENTS, INDIUM, DINITROGEN
TETRAOXIDE. AVOID ALL TYPES OF CONTAMINATION. EFTS OF OVEREXP:
DEPRESSION, SHOCK, DIZZINESS, DROWSINESS, DROP IN BLOOD PRESSURE,
RAPI D PULSE, LASSITUDE, STUPOR, IRRITABILITY, UNCONSCIOUSNESS AND
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:SEE ING 2
Melt/Freeze Pt:M.P/F.P Text:SEE ING 2
Vapor Pres:SEE ING 2
Vapor Density:SEE ING 2
Spec Gravity:SEE ING 2
Evaporation Rate & Reference:SEE INGREDIENT 2
Solubility in Water:SEE INGREDIENT 2
Appearance and Odor:SEE INGREDIENT 2
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
ACIDS, BASES, OXIDIZING AGENTS, REDUCING AGENTS, ALKALI METALS,
NITROGEN-FLUORINE COMPOUNDS, OLEUM, (SUPDAT)
Stability Condition to Avoid:DO NOT ALLOW THE SOLVENT TO EVAPORATE TO
DRYNESS.
Hazardous Decomposition Products:HIGHLY TOXIC FUMES OF CARBON MONOXIDE,
CARBON DIOXIDE, NITROGEN OXIDES AND HYDROGEN CYANIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MATERIALS SHOULD BE DISPOSED OF UNDER
CONDITIONS WHICH MEET FEDERAL, STATE, AND LOCAL ENVIRONMENTAL
CONTROL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:49F4341
CAGE:JO842
CAGE:24446
CAGE:JO842
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR.AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UNC ONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TERATHANE POLYETHER GLYCOLS
Preparer's Name:J. C. WATTS
CAGE:B0589
CAGE:B0589
CAGE:18873
============= Composition/Information on Ingredients =============
Ingred Name:POLY (OXY-1,4-BUTANEDIYL)-A-HYDRO-W-HYDROXY (AND
CAS#24979-97-3. LISTED BY TSCA ONLY UNDER THE FIRST NUMBER)
CAS:25190-06-1
Fraction by Wt: 100%
Ingred Name:OLIGOMERS; (OLIGOMERIC CYCLIC ETHER)
Fraction by Wt: 1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:FIRST AID PROC: CALL MD. NOTE: TO PREPARE ACTIVATED
CHARCOAL SLURRY, SUSPEND 50 GRAMS ACTIVATED CHARCOAL IN (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3: 400 ML WATER AND MIX THOROUGHLY. GIVE 5 ML/KG, OR
350 ML FOR AN AVERAGE ADULT.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THE COMPOUND IS A MILD SKIN AND EYE
IRRITANT. TOXIC EFFECTS IN ANIMALS FROM INHALATION OR INGESTION
INCLUDE LIVER ENLARGEMENT. TESTS IN BACTERIAL OR MAMMALIAN CELL
CULTURES DEMONSTRATE NO MUTAGENIC AC TIVITY. ORAL APPROXIMAT LETHAL
DOSE (ALD): TERATHANE 650 = 5,000 MG/KG; TERATHANE 1,000 = >11,000
MG/KG.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES. CALL MD. SKIN: FLUSH WITH WATER. INGEST: NO SPECIFIC
INTERVENTION IS INDICATED AS THE COMPOUND IS NOT LIKELY TO BE
HAZARDOUS BY IN GESTION. HOWEVER, CONSULT MD IF NECESSARY. INHAL:
REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O2/ARTF RESP) .
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:325F,163C
Extinguishing Media:DRY CHEMICAL, "ALCOHOL" FOAM, CARBON DIOXIDE,
WATER, SAND, OR DIRT.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
WATER SPRAY/DELUGE SHLD BE USED TO COOL SPILLS ON FIBROUS
INSULATION, ETC. OTHERWISE, ANY FIRE (SUPP DATA)
Unusual Fire/Explosion Hazard:SPILLS ON HIGH-SURFACE-AREA MATLS, SUCH
AS FIBROUS INSULATION, CAN DECOMPOSE RAPIDLY, RELEASING VERY FLAMM
TETRAHYDROFURAN, CO, ETC., & MAY IGNITE (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH LARGE SPILLS WITH PLENTY OF COLD WATER
TO FREEZE MATERIAL, THEN SCOOP UP. SOAK UP SMALL SPILLS WITH SAND,
EARTH, OR "OIL DRY." CLEAN FLOOR WITH ALCOHOL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE WITH STRONG INORGANIC
OXIDANTS SUCH AS NITRIC ACID. ABSORBS MOISTURE; KEEP CONTAINER
TIGHTLY CLOSED.
Other Precautions:STORE AT TEMPERATURES PREFERABLY OVER 45C(113F) TO
PREVENT SOLIDIFICATION. AVOID CONTACT WITH EYES, SKIN, AND
CLOTHING. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NO SPECIAL VENTILATION REQUIRED FOR NORMAL USE.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
FIRE FIGHT PROC: FIGHTING METHOD SUITABLE FOR OIL FIRES SHOULD BE USED.
EXPLO HAZ: AT TEMPERATURES AS LOW AS 100C(212F). CNDTNS (STAB):
SUCH AS FIBROUS INSULATION. MELTING POINT: >60.0F,>15.6C.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:SUPP DATA
Vapor Pres:NEGLIGIBLE
Vapor Density:NOT VOLAT
Spec Gravity:1 (8 LBS/GAL)
pH:NEUT
Evaporation Rate & Reference:NOT VOLATILE (BUAC=1)
Solubility in Water:0 TO 2%
Appearance and Odor:COLORLESS LIQUID OR WHITE WAXY SOLID (DEPENDING ON
GRADE), NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE WITH STRONG OXIDIZERS SUCH AS NITRIC ACID, CONCENTRATED
HYDROGEN PEROXIDE.
Stability Condition to Avoid:UNSTABLE AT TEMP ABOVE ABOUT 20C(390F); OR
AT TEMP AS LOW AS 100C(212F) IF IN CONTACT W/HIGH-SURFACE MATLS,
(SUPP DATA)
Hazardous Decomposition Products:CAN RELEASE VERY FLAMMABLE
TETRAHYDROFURAN, CO, ETC.
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY WITH FEDERAL, STATE, AND LOCAL
REGULATIONS. AQUATIC TOXICITY: MODERATELY TOXIC; 96-HOUR LC50: 1-50
MG/L.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LIGHTWEIGHT BODY FILLER FOR 310 BODY REPAIR KIT PINT
Preparer's Name:S ABDUL RAZZAK
CAGE:16522
CAGE:16522
============= Composition/Information on Ingredients =============
Ingred Name:DIETHYLENE GLYCOL, MALEIC ANHYDRIDE, PHTHALIC ANHYDRIDE
POLYMER *4/91*
CAS:26123-45-5
Fraction by Wt: >50%
Ingred Name:STYRENE, (MONOMER), SUSPECTED ANIMAL CARCINOGEN BY IARC &
ACGIH
CAS:100-42-5
RTECS #:WL3675000
Fraction by Wt: <20%
Other REC Limits:50 PPM
OSHA PEL:100 PPM
ACGIH TLV:S,50PPM/100STEL;9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM, MAGNESIUM SILICATE
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: <50%
OSHA PEL:20 MPPCF
ACGIH TLV:2 MG/CUM (RESP DUST)
Ingred Name:SODIUM BORATED SILICATE *4/91*
CAS:50815-87-7
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: UPPER RESPIRATORY
IRRITATION, DRUGGED, SLEEPY OR UNCONSCIOUS. EYES: IRRITATION. SKIN:
IRRITATION, RASH, DERMATITIS, & ECZEMATOUS ON THE BACK OF HANDS,
WRISTS OR FOREARMS.
Explanation of Carcinogenicity:STYRENE IS A SUSPECTED 2B ANIMAL
CARCINOGEN.
Effects of Overexposure:INHALATION: UPPER RESPIRATORY IRRITATION,
DRUGGED, SLEEPY OR UNCONSCIOUS. EYES: IRRITATION. SKIN: IRRITATION,
RASH, DERMATITIS, & ECZEMATOUS ON THE BACK OF HANDS, WRISTS &
FOREARMS.
Medical Cond Aggravated by Exposure:RESPIRATORY CONDITIONS SUCH AS
ASTHMA, CHRONIC BRONCHITITS, EMPHYSEMA, ETC.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER. SKIN: WASH THOROUGHLY W/SOAP &
WATER. INHALATION: REMOVE TO FRESH AIR. ADMINISTER ARTIFICIAL
RESPIRATION OR OXYGEN IF NEEDED. INGESTION: DON'T INDUCE VOMITING.
OBTAIN ME DICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Lower Limits:1.1%
Upper Limits:6.1%
Extinguishing Media:CO2, DRY CHEMICAL FOR SMALL FIRES; FOAM & WATER FOG
FOR LARGE FIRES.
Fire Fighting Procedures:VENT SMOKE & USE GAS MASK OR REMOTE AIR
SUPPLY. WEAR A MSHA/NIOSH APPROVED SELF-CONTAINED BREATHING
APPARATUS W/PROTECTIVE EQUIPMENT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES. INCREASE VENTILATION
TO MAXIMIZE VAPOR DISPERSAL. LARGE SPILL: DIKE TO PREVENT RUNOFF
INTO SEWERS/WATERWAYS. SHOVEL/WIPE. SWEEP/CLEAN W/INERT MATERIALS
SUCH AS SAND, VERMICULI TE & PLACE IN CLOSED CONTAINER FOR WASTE
DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY AREA. DON'T STORE
IN DIRECT SUNLIGHT. WORK W/ADEQUATE GENERAL & LOCAL EXHAUST
VENTILATION TO MINIMIZE EXPOSURE TO VAPORS.
Other Precautions:AVOID CONTACT W/SKIN/EYES/INHALATION. BOND/GROUND
CONTAINERS FOR TRANSFER TO PREVENT STATIC SPARKS. AVOID HEAT,
ELECTRICAL EQUIPMENT, SPARKS & OPEN FLAMES. AVOID IMPROPER ADDITION
OF PROMOTERS & OXIDI ZING AGENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH/MSHA APPROVED ORGANIC VAPOR/DUST
RESPIRATOR.
Ventilation:LOCAL EXHAUST: TO CONTROL THE EMISSION OF AIR CONTAMINANTS.
GENERAL: MAY ASSIST W/THE REDUCTION OF AIR CONTAMINANTS.
Other Protective Equipment:SAFETY SHOWERS & EYE WASH STATIONS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. CLEAN HANDS W/SOAP & WATER AFTER EVERY USAGE.
Supplemental Safety and Health
THIS PRODUCT CONTAINS MATERIALS CLASSIFIED AS NUISANCE PARTICULATES,
WHICH MAY BE PRESENT AT HAZARDOUS LEVELS ONLY DURING SANDING OR
ABRADING OF THE DRIED FILM. STYRENE VAPORS ARE UNINHIBITED & MAY CA
USE BLOCKAGE OF VENTILATION VENTS. PERIODIC INSPECTION IS ADVIDES
TO PREVENT BLOCKAGE.
================== Physical/Chemical Properties ==================
Spec Gravity:1.05-1.35
Evaporation Rate & Reference:LESS THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE PASTE W/STYRENE ODOR.
Percent Volatiles by Volume:<20/WT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, PEROXIDES & OTHER OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, OPEN FLAME, TEMPS >100F, SPARKS OR
OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:CO, CO2, LOW MOLECULAR WEIGHT
HYDROCARBONS & ORGANIC ACIDS.
Conditions to Avoid Polymerization:UNREGULATED CONTACT W/ORGANIC
PEROXIDES, EXPOSURE TO HEAT, OPEN FLAME, & STORAGE >100F.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PREPARAL 25
CAGE:EO198
CAGE:16449
CAGE:EO198
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA 313) (CERCLA)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: <25%
OSHA PEL:50 PPM (MFR)
ACGIH TLV:50 PPM, VAPOR, C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:POTASSIUM HYDROXIDE (CERCLA)
CAS:1310-58-3
RTECS #:TT2100000
OSHA PEL:2 MG/M3, C
ACGIH TLV:2 MG/M3, C
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SODIUM (1) NITRATE (1:1)
CAS:7631-99-4
RTECS #:WC5600000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:MAY CAUSE SLIGHT IRRITATION TO
EYES, SKIN AND RESPIRATORY SYSTEM. CHRONIC:NONE KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:IMMEDIATELY FLUSH W/LARGE AMOUNTS OF WATER FOR AT LEAST
15 MINUTES WHILE HOLDING EYELIDS OPEN. GET PROMPT MEDICAL ATTENTION
IF IRRITATION PERSISTS. SKIN:FLUSH W/LARGE AMOUNTS OF WATER, THEN
WASH W/SOAP & WATER. GET MEDICAL HELP IF IRRITATION PERSISTS.
INHAL:MOVE VICTIM TO FRESH AIR & TREAT SYMPTOMS. INGEST:CONTACT
LOCAL POISON CONTROL CENTER OR MD IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING MATERIALS.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NO SPECIAL PROCEDURES REQUIRED.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PERSONAL PROTECTIVE EQUIPMENT. CONTAIN
SPILLED MATERIAL BY DIKING. CLEAN UP W/NONCOMBUSTIBLE ABSORBANT
MATERIAL. FLUSH SPILL AREA W/WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED. IF AIRBORNE MISTS ARE
GENERATED, USE A NIOSH APPROVED DUST/MIST RESPIRATOR.
Ventilation:LOCAL EXHAUST MAY BE NECESSARY IF MATERIAL IS HEATED,
MISTED OR SPRAYED.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EYE PROT:& FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Spec Gravity:1.1
pH:10.4
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:PALE YELLOW LIQUID.
Percent Volatiles by Volume:<25
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MAGNAGLO MAGNETIC PARTICLE PREMIX 20B, (SUPP DATA)
CAGE:59042
CAGE:37676
CAGE:59042
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM BORATE, DECAHYDRATE; (BORAX). LD50: (ORAL,RAT) 2.6
G/KG
CAS:1303-96-4
RTECS #:VZ2275000
Fraction by Wt: 60-100%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:IRON (III) OXIDE. LD50:(ORAL,RAT) >5 G/KG
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:N/K
Ingred Name:POLY(OXY-1,2-ETHANEDIYL),
ALPHA-(NONYLPHENYL)-OMEGA-HYDROXY); (NONYLPHENOL POLYETHOXYLATE).
LD50:(ORAL,RAT) 3 G/KG
CAS:9016-45-9
RTECS #:MD0900000
Fraction by Wt: 3-7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:5-DECYNE-4,7-DIOL,2,4,7,9-TETRAMETHYL-
CAS:126-86-3
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: CAN IRRITATE IN DRY POWDER FORM.
EYES: IRRITATING. INHAL: NOT SIGNIFICANT BECAUSE 20B IS MIXED WITH
WATER WHEN IN USE. INGEST: NOT SIGNIFICANT IN SMALL MOUTHFUL
QUANTITIES.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:SKIN: RINSE OFF WITH WATER. USE SOOTHING LOTION. EYES: RINSE
CAREFULLY UNDER UPPER AND LOWER EYELIDS USING PLENTY OF WATER.
INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP).
IN GEST: GET MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:NOT APPLICABLE. EXTINGUISHING MEDIA SUITABLE FOR
SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:MOP UP OR SWEEP UP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING DUST. AVOID EYE
CONTACT WITH POWDER. AVOID REPEATED OR PROLONGED SKIN CONTACT WITH
AQUEOUS 20B SOLUTION.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR TRADE NAME/PART NO: 15 POUND PLASTIC PAIL. PH: 9 (1% IN WATER).
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NONE
Vapor Pres:NONE
Spec Gravity:1.2 (BULK)
pH:SUPDAT
Evaporation Rate & Reference:NONE
Solubility in Water:3%
Appearance and Odor:BROWN POWDER, NO ODOR.
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ORDINARY WASTE. DISPOSAL MUST BE
IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NEU-TRI(R)SOLVENT,PRODUCT CODE:56530
CAGE:86511
CAGE:86511
============= Composition/Information on Ingredients =============
Ingred Name:TRICHLOROETHYLENE (SARA III)
CAS:79-01-6
RTECS #:KX4550000
Fraction by Wt: 99%
OSHA PEL:100 PPM/100 STEL
ACGIH TLV:50 PPM/100,A5STEL;93
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS 4920 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:MAY CAUSE IRRITATION.SKIN:MAY
CAUSE IRRITATION AND DRYNESS.INGEST:MAY CAUSE GI TRACT
IRRITATION.INHAL:MAY CAUSE RESPIRATORY IRRITATION AND CNS
EFFECTS.CHRONIC:MAY DAMAGE LIVER AND KIDNEYS.
Explanation of Carcinogenicity:TRICHLOROETHYLENE IS LISTED
IARC-3,EPA-2B.
Effects of Overexposure:PAIN AND IRRITATION.NO CORNEAL INJURY SKIN:
SLIGHT IRRITATION INHAL:RESP SYS,HEART,LIVER,CNS,KIDNEYS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH SOAP AND
WATER.EYES:FLUSH WITH WATER FOR 15 MINUTES.INHAL:REMOVE TO FRESH
AIR.GIVE OXYGEN OR ARTIFICIAL RESPIRATION IF NEEDED.INGEST:DO NOT
INDUCE VOMITING. GET PROMPT QUALIFIED MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:8.0
Upper Limits:10.5
Extinguishing Media:WATER FOG
Fire Fighting Procedures:USE NIOSH APPROVED SCBA FOR FIREFIGHTING.
Unusual Fire/Explosion Hazard:NOT CONSIDERED A FLAMMABLE LIQUID UNDER
NORMAL INDUSTRIAL USE CONDITIONS
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTIVE EQUIPMENT.SM.
SPILL:MOP UP,WIPE UP OR SOAK UP IMMEDIATELY.REMOVE TO OUT OF
DOORS.LARGE SPILLS:EVACUATE AREA.CONTAIN LIQUID;TRANSFER TO CLOSED
METAL CONTAINERS. KEEP OUTOF WATER SUPPLY.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL PLACE. HANDLE WITH
REASONABLE CARE. KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:AVOID SKIN AND EYES CONTACT. DO NOT BREATH VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MESA APPR SCBA/AIR SUPP RESPIR.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:FULL PROTECTIVE CLOTHING,SAFETY SHOWER,EYE
WASH STATION
Work Hygienic Practices:WASH HANDS.SEPERATE WORK CLOTHES FROM STREET
CLOTHES.LAUNDER WORK CLOTHES BEFORE REUSE.KEEP FOOD OUT OF THE WORK
AREA.
Supplemental Safety and Health
MSDS DATED OCT 22, 1982.
================== Physical/Chemical Properties ==================
HCC:T4
Boiling Pt:B.P. Text:189F/87C
Vapor Pres:60
Vapor Density:4.53
Spec Gravity:1.46
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS LIQUID
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES,NAOH & KOH
Stability Condition to Avoid:NONE SPECIFIED
Hazardous Decomposition Products:ON COMBUSTION GIVES HCL,PHOSGENE &
CHLORINE
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES, DISPOSAL MUST BE IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:#630 MUTI-PURPOSE CERAMIC ADHESIVE (8475)
CAGE:EO770
CAGE:GIBS1
CAGE:EO770
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA (PETROLEUM SPIRITS OR BENZIN)
CAS:8030-30-6
RTECS #:SE7555000
Fraction by Wt: <5%
OSHA PEL:100 PPM
===================== Hazards Identification =====================
Effects of Overexposure:INHALATION: DIZZINESS/HEADACHE/UNCONSCIOUSNESS.
PROLONGED/REPEATED SKIN CONTACT MAY BE IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MINUTES. SKIN: WASH
AFFECTED AREA W/WATER. INHALATION: IF OVERCOME BY VAPORS, REMOVE
FROM EXPOSURE, RESTORE BREATHING. KEEP INDIVIDUAL CALM. CALL A
PHYSICIAN. INGES TION: TREAT SYMPTOMATICALLY AND CALL PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:>212F SCC
Lower Limits:1.0%
Upper Limits:6.0%
Extinguishing Media:FOAM, DRY CHEMICAL
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SCRAPE INTO CONTAINERS FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:VAPORS MAY IGNITE EXPLOSIVELY. PREVENT
BUILD UP OF VAPORS. KEEP AWAY FROM HEAT/SPARKS/OPEN FLA.
Other Precautions:AVOID PROLONGED BREATHING OF VAPORS AND REPEATED
CONTACT WITH SKIN. DON'T STORE ABOVE 120F. KEEP OUT OF REACH OF
CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WITH ADEQUATE VENTILATION.
Ventilation:PROVIDE VENTILATION TO KEEP BELOW TLV/PEL.
Other Protective Equipment:NONE
Supplemental Safety and Health
MSDS DATED: NOV 1985.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Vapor Pres:21
Vapor Density:>1
Spec Gravity:1.15
Evaporation Rate & Reference:(BU AC = 1) <1
Solubility in Water:MISCIBLE
Appearance and Odor:CREAM COLORED HEAVY PASTE W/SLIGHT AMMONIACAL
Percent Volatiles by Volume:54%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Hazardous Decomposition Products:CO AND ORGANIC COMPOUNDS OF UNKNOWN
STRUCTURE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:ASBESTOS FILLED SPIRAL WOUND GASKET
CAGE:72433
CAGE:72433
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE- NONE UNDER NORMAL CONDITIONS OF
USE. HOWEVER, GRINDING, SANDING OR MACHINING MAY PRODUCE NUISANCE
PARTICULATES THAT CAN CAUSE IRRITATION OF EYES, SKIN,
GASTROINTESTINAL TRACT AND RESPIRATORY PA SSAGES. CHRONIC- LONG
TERM EXPOSURE TO ASBESTOS CAN CAUSE IRREVERSIBLE ASBESTOSIS, LUNG
DISEASE, LUNG CANCER.
Explanation of Carcinogenicity:ASBESTOS IS REGULATED BY OSHA AS A
CARCINOGEN.
Effects of Overexposure:NONE UNDER NORMAL CONDITIONS OF USE. HOWEVER,
GRINDING, SANDING OR MACHINING MAY PRODUCE NUISANCE PARTICULATES
THAT CAN CAUSE IRRITATION OF EYES, SKIN, GASTROINTESTINAL TRACT AND
RESPIRATORY PASSAGES. MAY CAUSE NAUSEA, VOMITING AND DIARRHEA.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS SUCH AS DERMATITIS, RESPIRATORY PROBLEMS, LUNG DISEASE,
BRONCHIAL HYPER-REACTIVITY OR ANY CONDITION THAT MAY BE AGGRAVATED
BY NUISANCE DUST OR FIBERS.
======================= First Aid Measures =======================
First Aid:SEEK MEDICAL ATTENTION IF SYMPTOMS DEVELOP. IN CASE OF EYE
IRRITATION GENTLY RINSE WITH WATER FOR 15 MINUTES WHILE KEEPING
EYELIDS OPEN. DO NOT RUB EYES. SKIN: WASH FREQUENTLY WITH SOAP AND
WATER. INH ALATION: REMOVE TO FRESH AIR. INGESTION: DO NOT INDUCE
VOMITING. SEE A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NON FLAMMABLE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS OPERATED IN THE
POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:ASBESTOS FIBERS MAY BE RELEASED.
================== Accidental Release Measures ==================
Spill Release Procedures:TREAT DUST AS FREE ASBESTOS. DO NOT DRY SWEEP
OR USE COMPRESSED AIR. WET METHOD SHOULD BE USED FOR EXTRACTION OF
DUST AND DEBRIS. HIGH EFFICIENCY PARTICULATE APPARATUS (HEPA)
VACUUMS SHOULD BE USED. A VOID WATER-POLLUTION.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE- AVOID CREATING DUST BY
SANDING OR GRINDING THE PRODUCT.
Other Precautions:USE IN WELL VENTILATED AREA. AVOID BREATHING DUST OR
FIBERS. MINIMIZE CONTACT WITH SKIN. AVOID CONTACT WITH EYES. DO NOT
RAISE DUST. WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING OR
DRINKING. KEEP AWAY FROM REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED HIGH EFFICIENCY FIBERS/FUMES
RESPIRATOR WHEN AIRBORNE FIBER CONCENTRATIONS EXCEED THE PEL.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV. NONE NORMALLY REQUIRED.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER, WORK
CLOTHING AND APRON AS REQUIRED. DO NOT WEAR CONTACT LENSES
Work Hygienic Practices:DON'T TAKE PROTECTIVE GEAR/CLOTHING HOME IF
EXPOSED TO DUST. DON'T SHAKE. DON'T EAT IN AREA WHERE ASBESTOS/DUST
PRESENT.
Supplemental Safety and Health
AS MANUFACTURED, GASKET CONTAINING ASBESTOS DOES NOT PRESENT A HAZARD.
ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS, THEN ASBESTOS
FIBERS MAY BE RELEASED AND BECOME AIRBORNE.
================== Physical/Chemical Properties ==================
HCC:T6
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT BLUE - NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HYDROFLUORIC ACID AND CONCENTRATED ALKALI
Stability Condition to Avoid:NONE UNDER NORMAL OPERATING CONDITIONS.
Hazardous Decomposition Products:ASBESTOS FIBERS MAY BE RELEASED.
==================== Disposal Considerations ====================
Waste Disposal Methods:APPROVED LANDFILL. WASTE SHOULD BE CONTAINED IN
IMPERMEABLE BAGS, LABELED AND DISPOSED IN ACCORDANCE WITH ALL
LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BEN-GAY EXTRA STRENGTH SPORTS BALM
CAGE:EO144
CAGE:14040
CAGE:EO144
============= Composition/Information on Ingredients =============
Ingred Name:METHYL SALICYLATE
CAS:119-36-8
RTECS #:VO4725000
Fraction by Wt: 28%.
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
Ingred Name:MENTHOL
CAS:89-78-1
RTECS #:OT0350000
Fraction by Wt: 10%
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
Ingred Name:LANOLIN
CAS:8006-54-0
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
Ingred Name:STEARIC ACID
CAS:57-11-4
RTECS #:WI2800000
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
Ingred Name:GLYCERL STEARATE
CAS:123-94-4
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
Ingred Name:SORBITAN TRISTEARATE
CAS:26658-19-5
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
Ingred Name:POLYSORBATE-85
CAS:9005-70-3
RTECS #:WG2934500
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
Ingred Name:POTASSIUM STEARATE
CAS:593-29-3
RTECS #:WI4600000
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
Ingred Name:XANTHAN GUM
CAS:11138-66-2
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RAT (LD50)=6.8 G/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE, SKIN & RESPIRATORY
IRRITANT W/OVEREXPOSURE. POSSIBLE SKIN SENSITIZER. CHRONIC:NONE
KNOWN.
Effects of Overexposure:EYE: CAUSES IRRITATION, BURNING, & STINGING
SENSATION UPON CONTACT; SKIN CONTACT: MAY CAUSE IRRITATION &
SENSITIZATION; INHAL:MAY IRRITATE EYES, NOSE & THROAT; INGEST:
HARMFUL IF SWALLOWED.
Medical Cond Aggravated by Exposure:NONE REPORTED.
======================= First Aid Measures =======================
First Aid:EYES:IMMEDIATELY IRRIGATE W/PLENTY OF WATER FOR AT LEAST 15
MIN. OBTAIN MED ATTN; SKIN:IF SEVERE IRRITATION DEVELOPS, REMOVE
CONTAMINATED CLOTHING & WASH SKIN THOROUGHLY W/MILD SOAP & WATER.
GET MED A TTN; INHAL:REMOVE TO FRESH AIR. GIVE O*2/ARTIFICIAL
RESPIRATION AS NEEDED. GET MED ATTN; INGEST:INDUCE VOMITING. OBTAIN
MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:FOAM,CARBON DIOXIDE,DRY CHEMICAL, OR WATER SPRAY.
Fire Fighting Procedures:WEAR SELF-CONTND, POS PRESSURE, BRTHNG APP. &
FULL FIRE-FIGHTING PROTECTV GEAR. USE WATER TO KEEP CONTAINER COOL,
TO DILUTE & FLUSH SPILLS & REDUCE INTENSITY.
Unusual Fire/Explosion Hazard:DECOMPOSITION UNDER FIRE CONDITIONS WILL
GENERATE CARBON MONOXIDE, & PHENOL & MAY GENERATE OTHER TOXIC
VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:NOTIFY SAFETY PERSONNEL OF LEAKS OR
SPILLS.REMOVE IGNITION SOURCE,STOP RELEASE, & PROVIDE ADEQUATE
VENTILATION; COVER SPILL W/ INERT, NONCOMBUSTIBLE ABSORBANT
MATERIAL & PLACE IN DISPOSAL CONTAINER.DO NOT ALLOW SPILL TO FLOW
TO SEWER OR PUBLIC WT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY PLACE! STORE AS A
NFPA' CLASS III-B LIQUID. KEEP FIRE & SPARKS AWAY FROM CONTAINER.
Other Precautions:FOLLOW MFR'S PRECAUTIONARY LABELING. PROLONGED
CONTACT MAY CAUSE SKIN IRRITATION & SENSITIZATION. KEEP AWAY FROM
CHILDREN TO AVOID ACCIDENTAL POISONING. DONOT SWALLOW-HARMFUL.
DONOT USE W/ A HEATING P AD!
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CONSUMER PRODUCT: NONE SHOULD BE REQUIRED IF
USED I/A/W MFR'S DIRECTIONS. IN THE MANUFACTURING OF PRODUCT OR
WHERE LARGE BULD QUANTITIES EXIST, USE W/ ADEQUATE LOCAL EXHAUST
VENTILATION. IN CONFINED/E NCLOSED SPACE, USE NIOSH RESPR.
Ventilation:CONSUMER PRODUCT: NONE SHOULD BE REQUIRED IF USED I/A/W
MFR'S DIRECTIONS. OTHERWISE LOCAL EXHAUST & ELIMINATE FIRE/SPRK.
Other Protective Equipment:NONE-SHOULD BE NEEDED WHEN USED OR STORED AS
A CONSUMER PRODUCT. OTHERWISE, AS REQUIRED FOR TASK AT HAND.
Work Hygienic Practices:USE PRODUCT I/A/W MFR'S DIRECTIONS ON CONTAINER
FOLLOWING STATED PRECAUTIONS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.005-1.025
Solubility in Water:INSOLUBLE
Appearance and Odor:SMOOTH,WHITE,HOMOGENEOUS CREAM W/ A CHARACTERISTIC
FRAGRANCE.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS & STRONG ALKALIES. TRACES OF IRON WILL CAUSE
DISCOLORATION.
Stability Condition to Avoid:AVOID FIRE & SPARKS.
Hazardous Decomposition Products:UNDER FIRE CONDITIONS WILL GENERATE
CARBON MONOXIDE & PHENOL & OTHER POTENTIALLY TOXIC VAPORS.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MATERIAL CAN BE BURNED IN A SUITABLE
INCINERATOR OR DISPOSED OF VIA A LICENSED WASTE DISPOSAL COMPANY.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:92005 ERIN GREEN VOC COMPLIANT INDUSTRIAL (SUPDAT)
CAGE:IO479
CAGE:IO479
CAGE:09800
============= Composition/Information on Ingredients =============
Ingred Name:PROPANE; (PROPELLANT). VP: 780.0
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 13%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9495
Ingred Name:PROPANE, 2-METHYL-; (2-METHYLPROPANE (PROPELLANT)) VP:
780.0
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 13%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BENZENE, ETHYL-; (ETHYLBENZENE) (SARA 313). VP: 7.1
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 4%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/125STEL;9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE (SARA 313) (CERCLA). VP: 5.9
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 20%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE (SARA 313) (CERCLA). VP: 180.0
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 10%
OSHA PEL:1000 PPM
ACGIH TLV:750PPM/1000STEL;9495
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE) (MEK) (SARA 313)
(CERCLA). VP: 70.0
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 2%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM/300STEL;9495
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:BARIUM SULFATE
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: 16%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9495
Ingred Name:VOLATILE ORGANIC CONTENT AS A PERCENT BY WEIGHT PER BAAQMD
RULE 49: 62
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:EFTS OF OVEREXP:SOLVS. RATS EXPOSED TO TITANIUM DIOXIDE
DUST AT 250 MG/M3 DEVELOPED LUNG CANCER, HOWEVER, SUCH (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:EXPOS LEVELS ARE NOT ATTAINABLE IN WORKPLACE. RPTS
HAVE ASSOC RPTD & PRLNG OVEREXP TO SOLV W/PERMANENT (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:BRAIN AND NERVOUS SYSTEM DAMAGE.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH:REQUIRE TESTING FOR EXTRACTABILITY. DO NOT
INCINERATE. DEPRESSURIZE CONTAINER. DISPOSE OF IN (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:ACCORDANCE WITH FEDERAL, STATE, AND LOCAL
REGULATIONS REGARDING POLLUTION.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:INCINERATE, OR EXPOSE TO TEMP ABOVE 120F. HEAT
FROM SUNLIGHT, RADIATORS, STOVES, HOT WATER, & OTHER (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:HEAT SOURCES COULD CAUSE CONTAINER TO BURST. DO NOT
TAKE INTERNALLY. KEEP OUT OF THE REACH OF CHILDREN. (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND
INHALING THE CONTENTS CAN BE HARMFUL OR FATAL. (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:USE ONLY WITH ADEQUATE VENT. AVOID BREATHING VAPOR
AND SPRAY MIST. AVOID CONTACT WITH SKIN AND EYES. (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:THIS COATING MAY CONTAIN MATRL CLASSIFIED AS
NUISANCE PARTICULATES (LISTED AS DUST IN ING SECTION) WHICH(ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:MAY BE PRESENT AT HAZ LEVELS ONLY DURING
SANDING/ABRADING OF THE DRIED FILM. IF NO SPECIFIC DUSTS ARE (ING
20)
RTECS #:9999999ZZ
Ingred Name:ING 19: LISTED IN ING SECTION, THE APPLICABLE LIMITS FOR
NUISANCE DUSTS ARE ACGIH TLV 10 MG/M3 (TOTAL DUST), (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20:OSHA PEL 15 MG/M3 (TOTAL DUST), 5 MG/M3 (RESPIRABLE
FRACTION).
RTECS #:9999999ZZ
Ingred Name:RESP PROT:RESPIRATOR APPRVD BY NIOSH/MSHA FOR DUST WHICH
MAY BE GENERATED FROM THIS PRODUCT, UNDERLYING PAINT/ABRASIVE.
RTECS #:9999999ZZ
Ingred Name:VENT:REFER TO OSHA STANDARDS 1910.94, 1910.107, 1910.108.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATION OF EYES, SKIN AND
RESPIRATORY SYSTEM. MAY CAUSE NERVOUS SYSTEM DEPRESSION. EXTREME
OVEREXPOSURE MAY RESULT IN UNCONSCIOUSNESS AND POSSIBLY DEATH.
SIGNS AND SYMPTOMS OF OVEREXPOSURE:HE ADACHE, DIZZINESS, NAUSEA,
AND LOSS OF COORDINATION ARE INDICATIONS OF EXCESSIVE EXPOSURE TO
VAPORS OR (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:SPRAY MISTS. REDNESS & ITCHING/BURNING
SENSATION MAY INDICATE EYE/EXCESSIVE SKIN EXPOSURE. CHRONIC:PRLNGD
OVEREXPOS TO SOLV INGRED IN INGRED SECTION MAY CAUSE ADVERSE EFTS
TOLIVER, URINARY, BLOOD FORMING, CARDIO-VASCULAR, & REPRO SYS.
METHYL ETHYL KETONE MAY INCREASE THE NERVOUS SYS EFFECTS OF OTHER
(ING 9)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHALED: IF AFFECTED, REMOVE FROM EXPOSURE, RESTORE
BREATHING. KEEP WARM AND QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY
WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER
BEFORE RE-USE. EYE : FLUSH WITH LARGE AMOUNTS OF WATER FORAT LEAST
15 MINUTES. GET MEDICAL ATTENTION. INGEST: GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:<0F,<-18C
Lower Limits:0.9%
Upper Limits:12.8%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
H*2O SPRAY MAY BE INEFFECTIVE. IF H*2O IS USED, FOG NOZZLES ARE
PREFERABLE. H*2O MAY BE USED TO (SUPDAT)
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT, ELEC EQUIP, SPARKS, &
OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
APPLICATION TO HOT SURFACES REQS SPECIAL (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS, & OPEN
FLAME. VAPS WILL ACCUM READILY & MAY IGNITE EXPLOSIVELY. DURING USE
& UNTIL ALL VAPS ARE GONE KEEP AREA VENT.
Other Precautions:DO NOT SMOKE. EXTING ALL FLAMES, PILOT LIGHTS, &
HEATERS. TURN OFF STOVES, ELECTRIC TOOLS & APPLIANCES, & ANY OTHER
SOURCES OF IGNIT. CONSULT NFPA CODE. USE APPRVD BONDING & GROUNDING
PROCS. CONTENTS UNDER PRESS. DO NOT PUNCTURE, (ING 14)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERS EXPOS CANNOT BE CONTROLLED BELOW APPLIC
LIMS BY VENT, WEAR PROPERLY FITTED ORG VAP/PARTICULATE RESP APPRVD
BY NIOSH/MSHA FOR PROT AGAINST MATLS IN ING SECTION. WHEN
SANDING/ABRADING THE DRIEDFILM, WEAR A DUST/MIST (ING 22)
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPTABLE IF EXPOS TO MATLS IN
ING SECTION IS MAINTAINED BELOW APPLIC EXPOS LIMITS.(ING 23)
Other Protective Equipment:ANSI APPRVD EMER EYE WASH & DELUGE SHOWER .
WEAR SAFETY SPECTACLES WITH UNPERFORATED SIDESHIELDS.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
MFR'S TRADE NAME/PART #:MAINTENANCE COLORS-3. FIRE FIGHT PROC:COOL CLSD
CNTNRS TO PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN EXPOSED
TO EXTREME HEAT. EXPLO HAZ:PRECS. DURING EMER CONDTN OVEREXP T O
DECOMP PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE IMMED APPARENT.
OBTAIN MED ATTEN.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:<0F,<-18C
Vapor Pres:SEE ING
Vapor Density:HVR/AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:>65
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF METALS IN INGREDIENT SECTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THIS PROD MAY BE HAZ AS DEFINED UNDER
RESOURCE CONSERVATION & RECOVERY ACT (RCRA) 40 CFR 261. WASTE MUST
BE TESTED FOR IGNITABILITY TO DETERMINE APPLICABLE EPA HAZ WASTE
NUMBERS. WASTE FROM PRODS CONTAINING METHYL ETHYL KETONE MAY (ING
12)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:D.Z.N DIAZINON 2D
CAGE:8K340
CAGE:8K340
============= Composition/Information on Ingredients =============
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 RAT=8200MG/KG BODY WT.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:CHOLINESTERASE INHIBITION SYMTOMS CAN
INCLUDE HEAD,DIZZ,BLURRED VISION,WEAK,NAU,CRAMPS,DIARR,DISCOMFORT
IN CHEST,NERVOUSNESS,SWEAT,MIOSIS(PINPT
PUPILS),TEAR,SALIVATION,PULM EDEMA,UNCONTROLLABLE MUSCLE
TWITCHES,CONVULSIONS,CYANOSIS,COMA,LOSS OF REFLEXES & SPHINCTER
CNTRL.EYE/SKIN CONTACT CAUSE IRRIT.(SEE RESP PROT)
Explanation of Carcinogenicity:PER MSDS:DIAZINON NOT
ONCOGENIC/CARCINOGENIC/TERATOGENIC/MUTAGENIC.CRYSTALLINE SILICA IS
2A CATEGORY FOR IARC.
Effects of Overexposure:HEADACHE,DIZZ,BLURRED
VISION,WEAKNESS,NAU,CRAMPS,DIARR,DISCOMFORT IN
CHEST,NERVOUSNESS,SWEATING,MIOSIS,TEARING,SALIVATION,PULM
EDEMA,UNCONTROLLEABLE MUSCLE
TWITCHES,CONVULSIONS,CYANOSIS,COMA,LOSS OF R EFLEXES & SPHINCTER
CONTROL. EYE/SKIN IRRITATION.
Medical Cond Aggravated by Exposure:EXPO TO CHLOINESTERASE INHIBITORS
SHOULB BE RESTRICTED IN PERSON W/HEMOLYTIT ANEMIAS OR PRE-EXISTING
CHOLINESTERASE DEPRESSION.PERSON W/PRE-EXISTING RESP DISORDERS
SHOULD USE EXTRA CARE IN HNDLG PROD.
======================= First Aid Measures =======================
First Aid:POIS SUSPECTED IMMED CONTACT DR/HOSP/POIS CNTRL CNTR.GIVE
PROD NAME/TYP/AMT EXPO.DESCRIBE SYMPT/FOLLOW ADVICE
GIVEN.INGEST:FULLY CONSC IMMED GIVE 1-2GLASSES OF WATER.INDUCE
VOMIT.REPEAT TIL VOMIT FLUI D CLEAR.NEVER GIVE ANYTHING BY MOUTH
ART RESP IF NECESSARY PREFERABLY MECH MEANS.AVOID MOUTH/MOUTH
RESUSC.EYE:IMMED RINSE(SUPPLEME)
===================== Fire Fighting Measures =====================
Extinguishing Media:USE DRY CHEMICAL, FOAM, CO2 EXTINGUISHING MEDIA.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTH/SCBA.REMOVE
NONESSENTIAL PEOPLE FRM AREA TO PREVENT HUMAN EXPO TO
FIRE/SMOKE/FUMES/COMBUST PROD.DECONTAMIN BLDG/AREA/EQPMT BEF REUSE.
Unusual Fire/Explosion Hazard:THERM DECOMP PROD INCLUDE BUT NOT LIMITED
TO VAR ALIPHATIC ORGANOPHOSHPATES,SUB PYRIMIDINES,HYDROGEN
CYANIDE.PROD DOESN'T REPRESENT DUST EXPLO HAZ/SHOCK SENS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PPE INCLUDING DUST/PESTICIDE
RESP.SWEEPUP/KEEP DUST MIN.PLACE IN APPROVED CHEM WASTE CNTRN.WASH
AREA W/WATER/STRONG DETERG.ABSORB W/PET LITTER/OTHER
ABSORBENT.SWEEPUP/PLACE IN CHEM WASTE CNTNR.SE AL/DISPOSE.RINSE
W/WATER.DON'T CONTAMINH20 SUPPLY
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN WELL-VENTI SECURE AREA OUT OF
REACH OF CHILDREN/DOMESTIC ANIMALS.DO NOT STORE FOOD/BEV/TOBACCO
PRODUCTS IN STORAGE AREAS.
Other Precautions:TO AVOID BREATHING DUST WEAR DUST MASK.FRM HAZ DECOMP
PROD:TRACE AMTS OF WATER;RX WON'T OCCUR WHEN MIX W/LG AMTS OF
WATER.DR
NOTE:MORPHINE,THEOPHYLLINE,AMINOPHYLLINE,PHENOTHIAZINES,RESERPINE,F
UROSEMID E,ETHRACYNIC ACID CONTRAINDICATED IN POI
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DUST/PEST RESP FOR SPILLS/LEAKS. DR NOTE:PROD
ORGANOPHOSPHATE(CHOLINESTERASE-INHIBITING)INSECTICIDE.ATROPINE
ANTIDOTRAL FOR ORGANOPHOSPHATE POISON;SHOULD BE GIVEN IV IN
MULTIPLE DOSES AS NECESSARY TIL ATROPINIZED.2-PAM W/IN 24
HRS(OTHPREC)
Ventilation:STORE MATL IN WELL-VENTILATED AREA.
Other Protective Equipment:WEAR WATERPROOF BOOTS,LONGSLEEVED
SHIRTS,LONG PANTS,HAT.
Work Hygienic Practices:WASH CONTAMIN CLOTH BEF REUSE.ALWAYS WASH WELL
AFT HDNLG.PREVENT DRINK/EAT/TOBACCO USE/COSMETIC APPL IN AREA MATL
EXPO.
Supplemental Safety and Health
1STAID:W/LG AMTS OF RUNNING WATER,OPN EYELIDS.DO NOT APPLY MED AGENTS
UNLESS ADVICED BY DR.SKIN:WASH W/LOTS OF SOAP/WATER,INCLUDE
HAIR/UNDER FINGERNAILS.REMOVE CONTAMIN CLOTH.DO NOT APPLY MED
AGENTS U NLESS ADVICED BY DR.INHAL:MOVE TO FRESHAIR.APPLY ART RESP
IF NECESSARY.
================== Physical/Chemical Properties ==================
HCC:T4
Boiling Pt:B.P. Text:N/APPLICABL
Melt/Freeze Pt:M.P/F.P Text:N/APPLICABL
Vapor Pres:<10-4 @20C
Spec Gravity:30 LBS/FT3 BULK
pH:N/AVAI
Solubility in Water:40MG/L @20C
Appearance and Odor:GRAY-BROWN DUST, SLIGHT SULFUR-LIKE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:IMPURITY OF TOXIC CONCERN
THIONOTETRAETHYL-PYROPHOSPHATE(O,S-TEPP)FORM WHEN DIAZINON
CONTAINING PROD EXPO TO(OTHER PREC)
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT REUSE PROD CNTNRS.DISPOSE OF PROD
CNTNRS/WASTE CNTNRS/RESIDUES ACCORDING TO LOC/STATE/FED
HEALTH/ENVIRO REGS.QUESTIONS CONCERNING SAFE HDNLG OF D.Z.N
DIAZINON 2D REFER TO:CIBA-GEIGY CORP,ENVIRO SAFETY/COMPLIANCE
919-292-7100.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:3212 SPREAD WALL LATEX PAINT 3200 SERIES
CAGE:EO698
CAGE:01PD6
CAGE:EO698
============= Composition/Information on Ingredients =============
Ingred Name:GROG; CALCIUM-BARIUM PHOSPHOSILICATE, ALUMINUM SILICATE
FLUX *98-1*
CAS:66402-68-4
Fraction by Wt: 10-20%
Ingred Name:SODIUM ALUMINOSILICATE *98-1*
CAS:1344-00-9
Fraction by Wt: 1-5%
Ingred Name:AMORPHOUS SILICA, AMORPHOUS-DIATOMACEOUS EARTH
CAS:61790-53-2
RTECS #:HL8600000
Fraction by Wt: 1-5%
Other REC Limits:20 MCCPF (MSHA)
ACGIH TLV:10 MG/CUM DUST
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE (IARC - GROUP 3) *98-1*
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 5-10%
OSHA PEL:2 MG/CUM (RESP DUST)
ACGIH TLV:2 MG/CUM (RESP DUST)
Ingred Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
CARCINOGEN, IARC GROUP 3)*98-1*
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 5-10%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:AMORPHOUS SILICA GEL, SILICON DIOXIDE *98-1*
CAS:7631-86-9
Fraction by Wt: 1-5%
Ingred Name:VINYL ACRYLIC COPOLYMER
Fraction by Wt: 5-10%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 50-60%
Ingred Name:VOLATILE ORGANIC CONTENT: 26.27 G/L
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF RESPIRATORY
TRACT/LUNGS & ANESTHETIC EFFECTS. SKIN: IRRITATION & SENSITIZATION.
EYES: IRRITATION & CORNEAL INJURY. INGESTION: ANESTHETIC EFFECT.
CRYSTALLINE SILICA IS A CAUSE OF SILICOSIS, A NONCANCEROUS LUNG
DISEASE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DROWSINESS, DIZZINESS,
LIGHTHEADEDNESS, UNCOORDINATION, COUGHING, SNEEZING, RESPIRATORY
PROBLEMS, NARCOSIS, LOSS OF CONSCIOUSNESS, BLISTERING, TEARING,
REDNESS, HEADACHE, NAUSEA, DIARRHEA, GI DISTURBANCES.
Medical Cond Aggravated by Exposure:EYE, SKIN & RESPIRATORY DISORDERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE & SUPPORT BREATHING.
GIVE OXYGEN IF NECESSARY. SKIN: FLUSH W/WATER, THEN WASH THOROUGHLY
W/SOAP & WATER. EYES: FLUSH W/LARGE AMOUNTS OF WATER FOR 15 MINS.
OBTA IN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:DRY CHEMICAL/FOAM, WATER FOG, CO2.
Fire Fighting Procedures:WATER MAY BE USED TO COOL & PROTECT
CONTAINERS. USE FULL PROTECTIVE CLOTHING & SCBA. SCBA IS
RECOMMENDED.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT/FIRE. VAPORS ARE > THAN AIR & MAY TRAVEL
LONG DISTANCES TO A SOURCE OF IGNITION & FLASH BACK. (SUPP)
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE SOURCES OF IGNITION. VENTILATE AREA.
EVACUATE PERSONNEL. PLACE COLLECTED MATERIAL IN PROPER CONTAINER.
USE PROTECTIVE EQUIPMENT DURING CLEANUP. LARGE: SHUT OFF LEAK
SAFELY. DIKE & CONTAIN. P UMP TO STORAGE/SALVAGE VESSELS. (SEE
SUPP)
======================Handling and Storage ======================
Handling and Storage Precautions:STORE <100F. KEEP AWAY FROM
HEAT/SPARKS/OPEN FLAME/FREEZING. USE ONLY W/ADEQUATE VENTILATION.
KEEP CONTAINERS TIGHTLY CLOSED & UPRIGHT WHEN NOT IN USE
Other Precautions:DON'T TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
AVOID CONTACT W/SKIN, EYES & BREATHING OF VAPORS. EMPTY CONTAINERS
MAY CONTAIN HAZARDOUS RESIDUES. GROUND EQUIPMENT WHEN TRANSFERRING
TO PREVENT A CCUMULATION OF STATIC CHARGE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE RESPIRATORY PROTECTION IS REQUIRED, USE
ONLY NIOSH/MSHA APPROVED RESPIRATORS.
Ventilation:DILUTION/LOCAL EXHAUST TO PREVENT BUILDUP OF VAPORS.
Other Protective Equipment:EYE WASH, SAFETY SHOWER, IMPERVIOUS
CLOTHING, APRON.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS THOROUGHLY AFTER HANDLING/BEFORE EATING/SMOKING.
Supplemental Safety and Health
FIRE HZRD CONT'D: CLOSED CONTAINERS MAY BURST IF EXPOSED TO EXTREME
HEAT/FIRE. IN CLOSED TANKS, WATER/FOAM MAY CAUSE FROTHING/ERUPTION.
MAT TO AVOID CONT'D: SODIUM, POTASSIUM. SPILLS CONT'D: USE ABSOR
BENT TO PICKUP EXCESS RESIDUE. KEEP SALVAGEABLE & RINSE WATER OUT
OF SEWERS & WATER COURSES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Appearance and Odor:DUSTY ROSE WHITE
Percent Volatiles by Volume:75.83
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS/ACIDS/REDUCING AGENTS/BASES/ALUMINUM/ZINC/PEROXIDES/HYDROGEN
FLUORIDE/MAGNESIUM/CAUSTICS/MINERAL ACIDS. (SUPP)
Stability Condition to Avoid:ELEVATED TEMPS, ULTRAVIOLET LIGHT,
FREEZING, SPARKS/OPEN FLAME.
Hazardous Decomposition Products:CO, CO2, ACRID FUME, OXYGEN,
ALDEHYDES, ACIDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ELECTRO WASH C80, C16, C24, C240-4
CAGE:2M589
CAGE:21267
CAGE:2M589
============= Composition/Information on Ingredients =============
Ingred Name:TRICHLOROTRIFLUOROETHANE (FREON 113) (SARA III)
CAS:76-13-1
RTECS #:KJ4000000
Fraction by Wt: 70%
Other REC Limits:NONE DETERMINED
OSHA PEL:1000PPM/1250STEL
ACGIH TLV:1000PPM/1250STEL9192
Ozone Depleting Chemical:1
Ingred Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
Other REC Limits:NONE DETERMINED
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM/30000STEL;93
Ingred Name:TRICHLOROFLUOROMETHANE (CFC-11) (SARA III)
CAS:75-69-4
RTECS #:PB6125000
Other REC Limits:NONE SPECIFIED
OSHA PEL:1000 PPM
ACGIH TLV:C, 1000 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:YES
Health Hazards Acute and Chronic:INHALATION-VAPOR IS HEAVIER THAN AIR
AND CAN CAUSE SUFFOCATION BY REDUCING OXYGEN AVALIABLE FOR
BREATHING. EYE-LIQUID CONTACT CAN CAUSE DISCOMFORT. USUALLY NO
EXTENDED EFFECT. ORAL-ALTHOUGH ORAL TOXIC ITY IS LOW, INGESTION IS
TO BE AVOIDED.SKIN-REPEATED LIQUID CONTACT CAN CAUSE DEFATTING OF
THE SKIN.
Explanation of Carcinogenicity:COMPONENTS ARE NOT LISTED AS CARCINOGENS
BY IARC OR NTP. OSHA REGULATED-YES; OSHA AIR CONTAMINANT.
TOXIC-TES; LOW TOXIC
Effects of Overexposure:INHALATION-BREATHING HIGH CONCENTRATIONS OF
VAPOR CAN CAUSE LIGHT HEADEDNESS, GIGGINESS, SHORT OF BREATH & MAY
LEAD TO NARCOSIS, CARDIAC IRREGULARITIES, UNCONSCIOUSNESS & DEATH.
SKIN-IRRITATION OR RED NESS MAY OCCUR DUE TO DEFATTING.
INGESTION-MAY CAUSE NAUSEA & VOMITING. EYE-CONTACT MAY CAUSE
TEMPORARY DISCOMFORT.
Medical Cond Aggravated by Exposure:CARDIOVASCULAR DISEASE.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR & CALL A PHYSICIAN. IF NOT
BREATHING PERFORM CPR. IF BREATHING IS HARD GIVE OXYGEN. DO NOT
GIVE EPINEPHRINE OR SIMILAR DRUGS. SKIN:FLUSH WITH WATER.
INGESTION-NO SPECIFI C INTERVENTION IS INDICATED. HOWEVER, CONSULT
A PHYSICIAN IF NEEDED. DO NOT INDUCE VOMITING DUE TO ASPIRATION
HAZARD. EYE-IMMEDIATELY FLUSH WITH WATER FOR 15 MIN. SEEK MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE,AEROSOL
Extinguishing Media:NONFLAMMABLE.
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS (SCBA) MAY
BE REQUIRED IF CONTAINERS RUPTURE & CONTENTS ARE RELEASED UNDER
FIRE CONDITIONS.
Unusual Fire/Explosion Hazard:PRESSURIZED AEROSOL CONTAINERS MAY VENT,
RUPTURE OR EXPLODE AND ADD TO FYLING AND FALLING DEBRIS.
DECOMPOSITION MAY OCCUR.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE OPEN FLAMES OR OTHER
SOURCES OF IGNITION.. COLLECT SPILLED PRODUCT WITH ABSORBENT
MATERIAL AND PLACE IN CLOSED STEEL DRUMS FOR PROPER DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE NEAR SOURCES OF HEAT, IN
DIRECT SUNLIGHT, OR WHERE TEMPERATURES EXCEEED 120F. DO NOT
PUNCTURE OR DAMAGE CONTAINERS. ROTATE STOCK.
Other Precautions:THIS PRODUCT CONTAINS THE FOLLOWING TOXIC CHEMICALS
SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF THE
EMERGENCY PLANNING & COMMUNITY RIGHT TO KNOW ACT OF 1986: 70%,
TRICHLOROTRIFLUOROETHANE, CAS# 76-13-1.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO; GOOD VENTILATION/H.C. RESPIRATOR.
Ventilation:NO; AS NEEDED TO COMPLY WITH TLV.
Other Protective Equipment:YES; EYE BATH AND PROTECTIVE CLOTHING.
Work Hygienic Practices:NORMAL VENTILATION FOR STANDARD PROCEDURES;
LOCAL EXHAUST FOR LARGE RELEASES; MECHANICAL VENTILATION IN LOW
PLACES.
Supplemental Safety and Health
NOTE TO PHYSICAN: BECAUSE OF THE POSSIBLE INCREASED RISK OF ELICITING
CARDIAC ADYSRYTHMIAS, CATECHOLINAMINE DRUGS, SUCH AS EPINEPHRINE,
SHOULD BE USED ONLY AS A LAST RESORT IN LIFE THREATENING EMERGE
NCIES.
================== Physical/Chemical Properties ==================
HCC:V2
Boiling Pt:=23.9C, 75.F
Vapor Pres:334 MMHG
Vapor Density:4.6 @77F
Spec Gravity:1.46
Evaporation Rate & Reference:>1 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS LIQUID, FAINT SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALI & ALKALINE EARTH METAL-POWDERED ALUMINUM, BERYLLIUM, ZINC, AND
MAGNESIUM.
Stability Condition to Avoid:AVOID SPRAYING NEAR OPEN FLAMES OR RED HOT
SURFACES. DO NOT HEAT AEROSOL CONTAINERS ABOVE 120F/49C.
Hazardous Decomposition Products:COMPOUND CAN BE DECOMPOSED BY HIGH
TEMPERATURES FORMING HYDROCHLORIC & HYDROFLUORIC ACIDS & POSSIBLY
CARBONYL HALIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY WITH ALL FEDERAL, TATE, & LOCAL
REGULATIONS. DO NOT PUNCTURE OR INCINERATE AEROSOL CANS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HOT SEWER PIPE CLEANER, RED HOT B390
CAGE:7Y681
CAGE:7Y681
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 74%
Other REC Limits:2MG/M3 CEILING NIOSH
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SODIUM NITRATE
CAS:7631-99-4
RTECS #:WC5600000
Fraction by Wt: 6%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: BURNS/TISSUE PERFORATION OF
MUCOUS MEMBRANES OF THE MOUTH, THROAT, ESOPHAGUS, STOMACH, NAUSEA,
VOMITING, & DIARRHEA. SKIN/EYE: CORROSIVE,
BURNS/IRRITATION/DERMATITIS. INHALATION: DAMAGE TOTHE UPPER
RESPIRATORY TRACT/LUNG TISSUE, PNEUMONIA, INEBRIATION, HEADACHE,
NAUSEA, UNCONSCIOUSNESS, DIZZINESS, CYANOSIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYE: BURNS/DAMAGE/BLINDNESS. INHALATION:
CORROSIVE, DIZZINESS, ABDOMINAL CRAMPS, VOMITING, HEADACHE, MENTAL
IMPAIRMENT, CYANOSIS. SKIN: ASTHMA, SINUSITIS, DERMATITIS.
Medical Cond Aggravated by Exposure:ASTHMA, SINUSITIS, DERMATITIS
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/LARGE AMTS OF WATER FOR LEAST 15 MINS. SEEK MED
ATTN. SKIN: REMOVE/WASH CONTAMINATED CLOTHING/FOOTWEAR BEFORE
REUSE. INHALATION: GET PERSON OUT OF CONTAMINATED AREA TO FRESH
AIR. IF BREAT HING HAS STOPPED, RESUSCITATE/ADMINISTER OXYGEN. SEEK
MED ATTN. INGESTION: NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON. GIVE SEVERAL GLASSES OF MILK/WATER. SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL, CO2
Fire Fighting Procedures:MAY SUPPLY OXYGEN TO FIRE. AVOID DIRECT
CONTACT WITH WATER.
Unusual Fire/Explosion Hazard:SURFACES MAY BE SLIPPERY WHEN WET. KEEP
AWAY FROM EXPLOSIVES.
================== Accidental Release Measures ==================
Spill Release Procedures:MATERIAL SHOULD BE SWEPT UP FOR SALVAGE OR
DISPOSAL.
Neutralizing Agent:CAUSTIC SODA
======================Handling and Storage ======================
Handling and Storage Precautions:COOL DRY PLACE WITH PACKAGE TIGHTLY
SEALED. KEEP OUT OF REACH OF CHILDREN. KEEP DRY. AVOID SPARKS, FIRE
OR OPEN FLAMES. REMOVE DUST AS NECESSARY.
Other Precautions:AVOID CONTACT W/LEATHER OR WOOL. MAY DAMAGE OR STRIP
SOME PAINTS. WASH CONTAMINATED CLOTHING W/SOAP & WATER & DRY BEFORE
REUSE. DON'T AIR AGITATE THE SOLUTION, AS THIS WEAKNESS CLEANING
POWER. REMOVE DUST AS NECESSARY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:APPROVED DUST MASK
Ventilation:USE LOCAL EXHAUST VENTILATION TO KEEP <TLV
Other Protective Equipment:COVERALLS, SAFETY SHOES, SHOWER & EYEWASH.
Work Hygienic Practices:WASH/REMOVE CONTAMINATED CLOTHING/FOOTWEAR
BEFORE REUSE.
Supplemental Safety and Health
SPECIFIC GRAVITY: 1 HUNDRED LBS IS USUALLY PACKED IN A 12 GALLON DRUM.
CAUSTIC ALKALINE MIXTURE CONTAINING ALUMINUM CHIPS.
================== Physical/Chemical Properties ==================
pH:13.0%
Solubility in Water:APPRECIABLE
Appearance and Odor:RED/SILVER HETEROGENOUS GRANULAR POWDER, WHITE
GRANULES DYED RED; CLEANER ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
DON'T MIX W/STRONG ACIDS/HOT WATER. ALWAYS ADD COMPOUND SLOWLY TO COOL
WATER. MAY REACT VIOLENTY W/HIGH OXIDIZERS/WATER.
Stability Condition to Avoid:CONTACT W/COMBUSTIBLES, REDUCING AGENTS,
ORGANIC MATERIAL/STRONG OXIDIZING AGENT. SPARKS, FIRE, OPEN FLAMES.
Hazardous Decomposition Products:AMMONIACAL VAPORS, AMMONIA, HYDROGEN
CHLORIDE, NOX, CO, CO2, SULFUR DIOXIDE, HYDROGEN SULFIDE, NITROUS
OXIDES.
Conditions to Avoid Polymerization:CONTACT W/ALUMINUM, TIN, ZINC, &
ALLOYS CONTAINING THESE METALS.
==================== Disposal Considerations ====================
Waste Disposal Methods:IF MATERIAL CAN'T BE SALVAGE, IT SHOULD BE
DISPOSED OF IN A LANDFILL IN ACCORDANCE WITH LOCAL, STATE, &
FEDERAL REGULATIONS. DOT HAZARD CLASSIFICATION: CORROSIVE MATERIAL,
UN1823, CLEANING OR SCOURING COMPOUNDS NOI, O/T LIQ., CLASS 55.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:A25 GLASS CLEANER, 7596
CAGE:57040
CAGE:57040
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
OSHA PEL:400 PPM;500 STEL
ACGIH TLV:400 PPM;500 STEL
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:PROPANE, 2-METHYL-; (BUTANE)
CAS:75-28-5
RTECS #:TZ4300000
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: PROD EXISTS AS FOAM. INHAL OF
VAPORS ARE UNLIKELY ROUTE OF EXPOSURE. NO HARMFUL EFFECTS KNOWN FOR
AVAILABLE INFORMATION. SKIN CNTCT/ABSORP: NO EVIDENCE OF ADVERSE
EFFECT FROM AVAILABLE INFORMAT ION. PROLONGED OR REPEATED CONTACT
MAY CAUSE IRRITATION. INGESTION: CAN POSSIBLY CAUSE GI IRRIT, VOMIT
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: AND DIARRHEA. EYES: CAN CAUSE EYE
IRRIT, REDNESS, TEARING AND BLURRED VISION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH WITH WATER FOR AT LEAST 15 MIN, LIFTING UPPER AND
LOWER LIDS. GET MEDICAL ATTENTION. SKIN:WASH EXPOSED AREA WITH SOAP
AND WATER. INHAL: UNLIKELY ROUTE OF EXPOSURE. TREAT FOR
STRANGULATION. INGEST: DILUTE WITH WATER, DO NOT INDUCE VOMITING.
GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:WATER, DRY CHEMICAL, CO*2.
Fire Fighting Procedures:KEEP CNTNRS COOL USE EQUIP OR SHIELDING TO
PROT PERSONNEL AGAINST BURSTING, RUPTURING OR VENTING CNTNRS. WEAR
NIOSH/MSHA APPRVD SCBA & EQUIP .
Unusual Fire/Explosion Hazard:AT ELEVATED TEMPERATURES ABOVE 120F
CONTAINERS MAY VENT, RUPTURE OR BURST.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP AREA BY MOPPING OR WITH ABSORBENT
MATERIALS AND PLACE IN CLOSED CNTNRS FOR DISPOSAL. CONSULT FEDERAL,
STATE AND LOCAL DISPOSAL AUTHORITIES FOR APPROVED DISPOSAL
PROCEDURES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE AT TEMPERATURES ABOVE
120F.
Other Precautions:PLEASE READ AND FOLLOW THE DIRECTIONS ON THE PRODUCT
LABEL; THEY ARE YOUR BEST GUIDE TO USING THIS PRODUCT IN THE MOST
EFFECTIVE WAY AND GIVE THE NECESSARY SAFETY PRECAUTION TO PROTECT
YOUR HEALTH.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:UNDER NORMAL CONDITION NO RESPIRTORY PROTECTION
IS REQUIRED. NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NORMAL VENTILATION ADEQUATE.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
WASTE DISP METH: MANAGEMENT FACILITY. CONSULT FEDERAL, STATE AND LOCAL
DISPOSAL AUTHORITIES FOR APPROVED PROCEDURES.
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:55
Spec Gravity:0.978 (H*2O=1)
Solubility in Water:COMPLETE
Appearance and Odor:WHITE FOAM WITH SLIGHT AMMONIA ODOR.
Percent Volatiles by Volume:98
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS OR BASES, SELECTED AMINES.
Stability Condition to Avoid:DO NOT EXPOSE TO TEMPERATURES ABOVE 120F.
Hazardous Decomposition Products:THERMAL DECOMPOSITION IN THE PRESENCE
OF AIR MAY YIELD CARBON MONOXIDE AND/OR CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WHEN USE PROPERLY AEROSOL PRODUCTS DO NOT
GENERATE HAZ WASTE. EMPTY DE-PRESSUREIZED CNTNRS CANNOT BE REUSED &
SHLD BE WRAPPED & PUT IN TRASH COLLECTION. CANS WHICH ARE
PRESSURIZED OR CONTAIN LIQUID MU ST BE DISPOSED OF IN A PERMITTED
WASTE (SUPP DATA)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:D2675 DIETHANOLAMINE HYDROCHLORIDE
CAGE:21076
CAGE:21076
============= Composition/Information on Ingredients =============
Ingred Name:DIETHANOLAMINE HYDROCHLORIDE *95-4*
CAS:14426-21-2
RTECS #:KL3500000
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE HARMFUL BY INHALATION,
INGESTION/SKIN ABSORPTION. EYES: IRRITATING. INHALATION: IRRITATING
TO MUCOUS MEMBRANES & UPPER RESPIRATORY TRACT. SKIN: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/COPIOUS AMOUNTS OF WATER FOR 15 MINS. SKIN:
WASH W/SOAP & COPIOUS AMOUNTS OF WATER. INHALATION: REMOVE TO FRESH
AIR. GIVE CPR/OXYGEN IF NEEDED. INGESTION: WASH OUT MOUTH W/WATER
IF CONSC IOUS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:230F
Extinguishing Media:WATER SPRAY, CO2, DRY CHEMCIAL POWDER/APPROPRIATE
FOAM.
Fire Fighting Procedures:WEAR SCBA & PROTECTIVE CLOTHING .
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
COVER W/DRY LIME/SODA ASH, PICK UP, KEEP IN A CLOSED CONTAINER &
HOLD FOR WASTE DISPOSAL. VENTILATE AREA & WASH SITE AFTER MATERIAL
PICKUP IS COMPLETE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP TIGHTLY CLOSED. STORE IN A COOL
DRY PLACE.
Other Precautions:AVOID CONTACT & INHALATION. DON'T GET IN EYES,
SKIN/CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED
Other Protective Equipment:SUITABLE PROTECTIVE CLOTHING, SAFETY SHOWER
& EYE BATH.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Spec Gravity:1.17
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT
Hazardous Decomposition Products:CO, CO2, NITROGEN OXIDES, HYDROGEN
CHLORIDE GAS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE/MIX THE MATERIAL W/A COMBUSTIBLE
SOLVENT & BURN IN A CHEMICAL INCINERATOR EQUIPPED W/AN AFTERBURNER
& SCRUBBER, IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CUT AWAY DRAIN OPENER & CLEAR, 00975
CAGE:DUBOI
CAGE:0DHY4
CAGE:DUBOI
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: > 60%
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ALUMINUM (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: < 5%
OSHA PEL:15MG/M3 DUST/5 FUME
ACGIH TLV:10MG/M3 DUST; 9192
Ingred Name:PETROLEUM DISTILLATES
CAS:8002-05-9
RTECS #:SE7449000
Fraction by Wt: < 5%
OSHA PEL:400 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CORROSIVE TO SKIN, EYES, MUCOUS
MEMBRANES. DUSTS ARE CORROSIVE TO SKIN, EYES AND RESPIRATORY TRACT.
CHRONIC: SAME AS ACUTE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:SENSITIVE EYES, SKIN, IMPAIRED
PULMONARY FUNCTION.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. EYES: FLUSH THOROUGHLY WITH FRESH
WATER FOR AT LEAST 15 MIN, GET MEDICAL ATTENTION. SKIN: FLUSH WITH
FRESH WATER, WASH WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHES
AND SHOES. INGEST: GIVE MILK OR WATER. DO NOT INDUCE VOMITING, GET
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:CO2, DRY CHEMICALS OR FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH SMALL AMOUNTS TO DRAIN; COLLECT LARGE
AMOUNTS AND RETURN TO DRUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN DRY PLACE; KEEP CONTAINER
COVERED.
Other Precautions:DOT CORROSIVE: CAUTIONS ON CONTAINER LABEL. UN 1759
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:MECHANICAL VENTILATION PRODUCING NORMAL AIR DILUTION.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:C2
Boiling Pt:B.P. Text:NONE
Evaporation Rate & Reference:< 1 (N-BUTYL ACETATE=1)
Solubility in Water:20 %
Appearance and Odor:WHITE TO TAN POWDER; MILD ODOR.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
FLAMMABLE LIQUIDS, ACTIVE METALS, ORGANIC HALOGEN COMPOUNDS, STRONG
ACIDS CAUSE VIOLENT REACTIONS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CO WITH INCOMPLETE COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:USE UNTIL LESS THAN 1 INCH REMAINS IN CONTAINER,
EMPTY CONTAINER TRIPLE RINSE WITH WATER, ADD TO OPERATION. REMOVE
OR DEFACE LABEL BEFORE SELLING CONTAINER OR DISPOSAL. HIGHLY
ALKALINE; PH ADJUSTMENT; NO PHOSPHATES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:424 LINK-LIFE CHAIN LUBE
CAGE:27732
CAGE:27732
============= Composition/Information on Ingredients =============
Ingred Name:ASPHALT
CAS:8052-42-4
RTECS #:CI9900000
ACGIH TLV:5 MG/M3 (FUME)
Ingred Name:RUST INHIBITOR
CAS:68606-26-4
Ingred Name:LIGHTWEIGHT OIL; (PETROLEUM OIL, LIGHT)
Other REC Limits:5MG/M3 OIL MIST(MFR)
Ingred Name:FATTY ESTER, REFINED
CAS:61789-97-7
Ingred Name:THICKENING AGENT; (THICKENER)
Ingred Name:GREASE, PETROLEUM; (PETROLEUM)
CAS:8009-03-8
Ingred Name:SUPP DATA: IN HIGH VISOCSITY, LOW VOLATILITY PROD, I.E.
MOST OILS AND GREASES.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:PROPERLY. FLUSH AREA W/WATER TO REMOVE TRACE
RESIDUE. SM SPILL: TAKE UP W/AN ABSORB MATL & DISPOSE OF (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:PROPERLY. PROD IS AN "OIL" UNDER CLEAN WATER ACT.
KEEP OUT OF SURF WATERS & ANY WATER COURSES/SEWERS (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: ENTERING OR LEADING TO SURFACE WATERS.
RTECS #:9999999ZZ
Ingred Name:RESP PROT: AIR-PURIFYING RESPIRATOR FOR ORGANIC VAPORS AND
PARTICULATES.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/WATER FOR @ LST 15 MIN WHILE HOLDING LIDS OPEN.
GET MED ATTN. SKIN: REMOVE CONTAMD CLTHG & WIPE EXCESS OFF. WASH
W/SOAP & WATER/A WATERLESS HAND CLEANER FOLLOWED BY SOAP & WATER.
DO NOT R EUSE CLTHG UNTIL THORO CLEANED. IF IRRIT PERSISTS, GET MED
ATTN. INHAL: REMOVE TO FRESH AIR & PROVIDE OXYGEN IF BRTHG IS
DFCLT. GET MED ATTN. INGEST:DO NOT INDUCE VOMIT. IN GEN, NO TRTMT
(SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:380F,193C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, WATER FOG/FOAM. DO
NOT USE DIRECT WATER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . COOL FIRE-EXPOSED CONTAINERS W/WATER.
Unusual Fire/Explosion Hazard:WHEN BURNED, CARBON MONOXIDE, CARBON
DIOXIDE AND WATER ARE FORMED. PRODUCT WILL FLOAT ON WATER AND CAN
BE REIGNITED ON THE SURFACE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH/MSHA APPRVD RESP & PROT CLTHG AS
APPROP. SHUT OFF SOURCE OF LEAK IF SAFE TO DO SO. DIKE & CNT.
REMOVE W/VACUUM TRUCKS/PUMP TO STOR/SALVAGE VESSELS. SOAK UP
RESIDUE W/AN ABSORB SUCH AS CLAY, SAND/OTHER SUITABLE MATL;
DISPOSE OF (ING 8)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE W/ADEQ
VENT. AVOID INHALATION OF MIST AND VAPORS IF HEATED; KEEP AWAY FROM
OPEN FLAME AND HIGH TEMPERATURE.
Other Precautions:AVOID FREQ/PRLNGD SKIN CONT. WASH W/SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING/USING TOILET FACILITIES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE THERE IS POTNTL FOR GENERATION OF MISTS
ABOVE 5 MG/M3, NIOSH/MSHA APPRVD RESP PROT AGAINST OIL MIST SHOULD
BE WORN TO PVNT OVEREXP. I/A/W OSHA STD 29CFR1910.134 USE EITHER AN
NIOSH/MSHA APPRVD A TM-SUPPLYING RESP/AN (ING 11)
Ventilation:LOC EXHAUST-NOT REQUIRED AT NORMAL TEMPERATURES.
Other Protective Equipment:PROT CLTHG SUCH AS APRONS, COVERALLS AND
BOOTS.
Work Hygienic Practices:LAUNDER CONTAMD CLTHG BEFORE REUSE. PROPERLY
DISPOSED OF CONTAMD LEATHER ARTICLES, INCL SHOES THAT CANNOT BE
DECONTAMD.
Supplemental Safety and Health
SPEC GRAV: 0.95 TYPICAL(H*2O=1). HAZ DECOMP: DEPENDENT ON COMBUST
CNDTNS. A COMPLEX MIXT OF AIRBORNE SOLID, PARTICULATES & GASES WILL
EVOLVE WHEN MATL UNDERGOES PYROLYSIS/COMBUST. FIRST AID PROC: IS N
EC UNLESS LG QTY OF PROD ARE INGESTED. HOWEVER, GET MED ADVICE.
NOTE TO PHYS: IN GEN, EMESIS INDUCTION IS UNNEC (ING 7)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>500F,>260C
Spec Gravity:SUPP DATA
Solubility in Water:NIL
Appearance and Odor:BLEACH LIQUID, HYDROCARBON ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS.
Stability Condition to Avoid:AVOID HEAT, OPEN FLAMES.
Hazardous Decomposition Products:CARBON MONOXIDE & OTHER UNIDENTIFIED
ORG CMPDS MAY BE FORMED UNDER COMBUST. THERMAL DECOMP PROD ARE
HIGHLY (SUPP DATA)
==================== Disposal Considerations ====================
Waste Disposal Methods:ALL WASTE MATERIAL SHOULD BE PACKAGED,
IDENTIFIED, TRANSPORTED AND DISPOSED OF IN COMPLIANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MAPP GAS (0916-0009)
CAGE:63026
CAGE:63026
============= Composition/Information on Ingredients =============
Ingred Name:LPG (LIQUEFIED PETROLEUM GAS)
CAS:68476-85-7
RTECS #:SE7545000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9495
Ingred Name:METHYL ACETYLENE PROPADIENE
CAS:56960-91-9
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-IF INHALED, CAN CAUSE CNS
DEPRESSION. MAY CAUSE HEADACHES & DIZZINESS. MAY CAUSE ASPHYXIATION
IN HIGH CONCENTRATIONS. PROLONGED INHALATION MAY BE HARMFUL.
CONTACT W/LIQUID CAN CAUSE EYE BURNS. N O SKIN HAZARD IN NORMAL
USE. INGESTION IS NOT LIKELY AS PRODUCT IS A GAS AT ROOM
TEMPERATURE. CHRONIC-UNKNOWN.
Explanation of Carcinogenicity:MFR GAVE THE ABOVE LISTINGS ON THE MSDS
BUT NO OTHER COMMENTS WERE RECORDED.
Effects of Overexposure:INHALED:CNS DEPRESSION, HEADACHES & DIZZINESS.
ASPHYXIATION IN HIGH CONCENTRATIONS. EYE:BURNS. SKIN:NO HAZARD.
INGESTION:NOT LIKELY.
Medical Cond Aggravated by Exposure:MFR GAVE NO INFORMATION ON MSDS.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTIFICIAN RESPIRATION &/OR GIVE OXYGEN BY TRAINED PERSONNEL. SEEK
MEDICAL ATTENTION. EYE:IMMEDIATELY FLUSH EYES W/PLENTY OF WATER.
GET MEDICAL A TTENTION IF IRRITATION PERSISTS. SKIN:AVOID BREATHING
VAPORS FROM HEATED MATERIAL. INGESTION:NO EMERGENCY CARE
ANTICIPATED.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:-144F,-98C
Autoignition Temp:Autoignition Temp Text:850F
Lower Limits:3.0
Upper Limits:11.0
Extinguishing Media:*DO NOT EXTINGUISH!* USE WATER TO COOL CONTAINERS.
IF SAFE, SHUT OFF FUEL. VENTILATE TO PREVENT EXPLOSIVE FUEL/AIR
MIX.
Fire Fighting Procedures:EVACUATE AREA & FIGHT FIRE FROM SAFE DISTANCE.
DO NOT EXTINGUISH UNTIL GAS SHUT-OFF IS POSSIBLE. WEAR SCBA (NIOSH
PRESSURE DEMAND) & FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:FLAMMABLE GAS. CAN READILY FORM EXPLOSIVE
MIXTURES AT OR ABOVE FLASHPOINT. FLASHBACK ALONG VAPOR TRAIL IS
POSSSIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINMATE IGNITION SOURCES INCLUDING INTERNAL
COMBUSTION ENGINES & POWER TOOLS. ISOLATE HAZARD AREA. KEEP
UNNECESSARY & UNPROTECTED PERSONNEL FROM ENTERING. AVOID BREATHING
VAPORS. AVOID CONTACT W/EY ES, SKIN & CLOTHING.
Neutralizing Agent:MFR GAVE NO INFORMATION ON MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:USE SPARK-PROOF TOOLS & EXPLOSION
PROOF EQUIPMENT. GROUND & BOND CONTAINERS WHEN TRANSFERRING
MATERIAL. DO NOT REUSE CONTAINER. STORE IN COOL,DRY AREA
Other Precautions:"EMPTY" CONTAINERS RETAIN RESIDUE & CAN BE DANGEROUS.
DO NOT PRESSUREIZE,CUT,WELD,BRAZE,SOLDER,DRILL,GRIND OR EXPOSE
CONTAINERS TO HEAT,FLAME,SPARKS,STATIC ELECTRICITY OR OTHER
IGNITION SOURCES. RETUR N EMPTY CONTAINERS TO RECONDITIONER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A RESPIRATORY PROTECTION PROGRAM THAT MEETS OSHA
1910.134 & ANSI Z88.2 REQUIREMENTS MUST BE FOLLOWED WHENEVER
WORKPLACE CONDITIONS WARRENT A RESPIRATOR'S USE.
Ventilation:USE PROCESS ENCLOSURES, LOCAL EXHAUST OR OTHER ENGINEERING
CONTROLS TO KEEP AIRBORNE LEVELS BELOW RECOMMENDED LIMITS.
Other Protective Equipment:MFR GAVE NO INFORMATION ON MSDS.
Work Hygienic Practices:MFR:? HMIS:USE GOOD INDUSTRIAL HYGIENE
PRACTICES. MINIMIZE CONTACT & WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
SHIELD.
================== Physical/Chemical Properties ==================
HCC:G2
NRC/State Lic Num:NONE
Boiling Pt:B.P. Text:-54F,-48C
Melt/Freeze Pt:M.P/F.P Text:ND
Vapor Pres:97 PSIG
Vapor Density:>1
Spec Gravity:0.57 (LIQUID)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS GAS; CHARACTERSITIC PUNGENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NATURAL RUBBER, COPPER ALLOYS > 65%, SILVER. MERCURY, HALOGENS, ACIDS,
POTASSIUM, METALLIC SODIUM, OXIDIZERS.
Stability Condition to Avoid:MFR GAVE NO INFORMATION ON MSDS.
Hazardous Decomposition Products:SMOKE, OXIDES OF CARBON.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT ATTEMPT TO DISPOSE OF WASTE OR UNUSED
QUANTITIES. RETURN IN THE SHIPPING CONTAINER PROPERLY LABELED, WITH
VALVE PROTECTION CAP IN PLACE TO SUPPLIER FOR PROPER DISPOSAL.
| 0 | gloves_not_mandatory |
=======================================================
Product ID: 7027, MIRROLAC INT-EXT ALKYD-URETHANE (SUPP DATA)
Cage: EO559
=======================================================
Contractor Summary
=======================================================
Cage: EO559
Box: 7600
Cage: 6R552
Box: 7600
=======================================================
Ingredients
=======================================================
% Wt: 45
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Cas: 64742-88-7
68F; LEL:1.0%
% Wt: 45
OSHA PEL: 525 MG/M3 (MFR)
ACGIH TLV: 525 MG/M3 (MFR)
------------------------------
Cas: 147-14-8
RTECS #: GL8510000
% Wt: <5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 13463-67-7
RTECS #: XR2275000
% Wt: <5
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST
------------------------------
% Wt: <5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
RTECS #: 9999999VO
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
ATTENTION.
-----------------------------
PNEUMONITIS WHICH CAN BE FATAL.
-----------------------------
-----------------------------
APPROVED CHEM/MECH FILTERS DESIGNED TO REMOVE
-----------------------------
AREAS, WEAR NIOSH APPRVD AIR SUPPLIED RESPS OR
-----------------------------
& SANDING MATL COATED W/PROD. FOLLOW
-----------------------------
-----------------------------
AREAS, & TO REMOVE SANDING DUSTS OF DRIED COATING
-----------------------------
COATED W/PROD. HVY SOLV VAPS SHOULD BE RECOVERED
-----------------------------
BE ELIMINATED.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:INHAL:IRRIT OF RESP TRACT; MAY AFFECT BRAIN/NERV SYS
CAUSING DIZZ, HDCH, NAUS, WEAK & FATG. EXTREME EXPOS CAN RSLT IN UNCON
& EVEN RESP ARREST. EYE/SKIN CONT:CAUSES IRRIT. INGEST:CAN CAUSE STOM
&/OR INTESTINAL IRRIT, NAUS, VOMIT & DIARR. ASPIR OF VOMIT CAN CAUSE
CHEM PNEUM, WHICH CAN BE FATAL. (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZS:CHRONIC:RPTS HAVE ASSOC RPTD
& PRLNGD OCCUP OVEREXP TO SOLVS W/PERM BRAIN & NERV SYS DMG. PRLNGD
& RPTD BRTHG OF SPRAY MIST &/OR SANDING DUST OVER A PERIOD OF YRS MAY
CAUSE DUST DISEASE OF T HE LUNGS. WARNING:THIS PROD MAY CNTN A CHEM KNOWN TO
THE STATE OF CA TO CAUSE CANCER, BIRTH DEFECTS/OTHER REPRO HARM.
Medical Cond Aggravated By Exposure: NONE WHEN USED IN ACCORDANCE WITH SAFE
HANDLING AND USE INFORMATION (SEE CONTROL MEASURES).
First Aid: INHAL:LEAVE AREA TO GET FRESH AIR. IF CONTINUED DFCLTY IN BRTHG IS
EXPERD, SUMMON MED ASSISTANCE IMMED. IF BRTHG CEASES, RESTORE USING APPRVD
CPR TECHNIQUES & SUMMON MED ASSISTANCE IMMED. EYES:FLUSH W /LG AMTS OF
WATER FOR @ LST 15 MIN. GETMED ASSISTANCE. SKIN:WASH AREA THORO W/SOAP &
WATER. REMOVE SOILED CLTHG. GET MED ASSISTANCE IF IRRIT PERSISTS. INGEST:DO
NOT INDUCE VOMIT. CONSULT MD
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL IGNIT SOURCES (HEAT, FLAME). DO NOT SMK.
AVOID BRTHG VAPS. BEFORE ATTEMPTING CLEAN-UP REFER TO HAZ CAUTN INFO IN OTHER
SECTIONS OF MSDS. VENT AREA. CNTN SPILLED MATL & REMOVE W/INERT ABSORB
& NON-SPKING TOOLS. STORE IN CLSD CNTNRS
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS. INCINERATE ONLY IN APPROVED FACILITY. DO NOT INCINERATE CLOSED
CONTAINERS.
Handling And Storage Precautions: KEEP AWAY FROM HEAT & FLAME. DO NOT SMK.
PVNT BUILD-UP OF VAPS BY MAINTAINING CONTINUOUS FLOW OF FRESH AIR. DO NOT
STORE >120F/NEAR FIRE/OPEN FLAME.
Other Precautions: STORE LG QTYS IN BLDGS DESIGNED TO COMPLY W/OSHA 1910.106.
KEEP CNTNR CLSD WHEN NOT IN USE. DO NOT TRANSFER CONTENTS TO BOTTLES/OTHER
UNLBLED CNTNRS. DO NOT REUSE EMPTY CNTNRS. KEEP OUT OF REACH OF CH ILDREN. DO
NOT GET ON SKIN/IN EYES.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: SCC
Flash Point Text: 102F,39C
Lower Limits: SEE ING 2
Extinguishing Media: IN CASE OF FIRE, USE CO*2, DRY CHEM, FOAM/OTHER NATIONAL
FIRE PROT ASSOC (NFPA) APPROVED METH FOR TREATING CLASS B FIRE.
Fire Fighting Procedures: SUMMON PROFESSIONAL FIREFIGHTERS. WEAR NIOSH APPRVD
SCBA & FULL PROT EQUIP (FP N). WATER SPRAY MAY BE INEFTIVE. IF WATER IS
USED, FOG NOZZS ARE PREF. (SUPDAT)
Unusual Fire/Explosion Hazard: KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM HEAT
& FLAME. DUE TO PRESS BUILD-UP, CLSD CNTNRS EXPOSED TO EXTREME HEAT MAY
EXPLODE. NEVER USE WELDING/CUTTING (SUPDAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: DO NOT BRTHE VAPS, SPRAY MIST/SANDING DUST. WHEN SPRAY
APPLIED IN OUTDOOR/OPEN AREAS W/UNRESTRICTED VENT, & DURING
SANDING/GRINDING OPERATIONS, USE NIOSH APPRVD MECH FILTER RESP TO REMOVE
SOLID AIRBOR NE PARTICLES OF OVERSPRAY &
Ventilation: USE ONLY W/ADEQ VENT. PROVIDE GEN DILUTION/LOC EXHST VENT IN VOL
& PATTERN TO KEEP AIR CONTAM CONC BELOW CURRENT
Other Protective Equipment: ANSI APPRVD EMER EYEWASH & DELUGE SHOWER (FPN). DO
NOT GET ON SKIN. SOLV IMPERMEABLE CLTHG & BOOTS TO PVNT CONT ARE REC.
Work Hygienic Practices: REMOVE & WASH SOILED CLOTHING BEFORE REUSE. WASH HANDS
BEFORE EATING, SMOKING OR USING THE WASHROOM.
Supplemental Safety and Health: MFR TRADE/PART #:ENAMEL-GLOSS NAVY BLUE. FIRE
FIGHT PROC:IF EXPOSED TO FIRE/EXTREME HEAT, WATER SHOULD BE USED TO COOL CLSD
CNTNRS & TO PVNT PRESS BUILD-UP/POSS AUTO-IGNIT. EXPLO HAZS:ON/NEAR CNTNR
(E VEN EMPTY) AS PROD/ITS RESIDUE MAY IGNITE. DURING EMER CNDTNS, OVEREXP TO
DECOMP PRODS MAY CAUSE HLTH HAZ.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >300F,>149C
Vapor Pres: SEE ING 2
Vapor Density: HVR/AIR
Spec Gravity: 0.943 (FP N)
Evaporation Rate & Reference: SLOWER THAN ETHER
Solubility in Water: NEGLIGIBLE
Appearance and Odor: CHARACTERISTIC OF SOLVENTS LISTED IN HAZARDOUS
INGREDIENTS.
Percent Volatiles by Volume: 55
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: MAY CAUSE HAZ FUMES WHEN HEATED TO DECOMP.
FUMES MAY CNTN CARBON MONOXIDE & DIOXIDE & OXIDES OF METALS LISTED IN INGS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: 7027, MIRROLAC INT-EXT ALKYD-URETHANE (SUPP DATA)
Cage: EO559
Assigned IND: Y
Company Name: DEVOE & RAYNOLDS CO, INC.
Street: UNKNOWN
PO Box: 7600
Zipcode: 00000
Label Required IND: Y
Date Of Label Review: 09/20/1996
Status Code: C
Label Date: 09/20/1996
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE LIQUID. CLASS II. ACUTE:INHAL:IRRIT OF RESP
TRACT; MAY AFFECT BRAIN/NERV SYS CAUSING DIZZ, HDCH, NAUS, WEAK & FATG.
EXTREME EXPOS CAN RSLT IN UNCON & EVEN RESP ARREST. EYE/SKIN CONT:CAUSES
IRRIT. INGEST:CAN CAUSE STOM &/OR INTESTINAL IRRIT, NAUS, VOMIT &
DIARR. ASPIR OF VOMIT CAN CAUSE CHEM PNEUM, WHICH CAN BE FATAL. CHRONIC:RPTS
HAVE ASSOC RPTD & PRLNGD OCCUPATIONAL OVEREXP TO SOLVS W /PERM BRAIN
& NERV SYS DMG. PRLNGD & RPTD BRTHG OF SPRAY MIST &/OR SANDING
DUSTOVER PERIOD OF YRS MAY CAUSE DUST DISEASE OF LUNGS. WARNING: PROD MAY
CNTN CHEM KNOWN TO CA TO CAUSE CANCER, BIRTH DEFECT S/OTHER REPRO HARM.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ORANGE MUSCLE,READY-TO-USE
Resp. Party Other MSDS Num.:#516
CAGE:0SXN4
Contract Num:SP0450-99-M-C299
CAGE:0SXN4
============= Composition/Information on Ingredients =============
Ingred Name:D-LIMONENE
CAS:68647-72-3
Code:F
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT PROVIDED.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE EFFECTS: MAY CAUSE EYE, SKIN,
MUCOUS MEMBRANE IRRITATION ON PROLONGED CONTACT. CHRONIC HEALTH
EFFECTS HAVE NOT BEEN REPORTED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:MAY CAUSE EYE, SKIN, MUCOUS MEMBRANE IRRITATION
ON PROLONGED CONTACT.
Medical Cond Aggravated by Exposure:MAY AGGREVATE PRE-EXISTING SKIN
CONDITION.S
======================= First Aid Measures =======================
First Aid:EYES: WASH WITH WATER FOR 15 MINUTES. CALL PHYSICIAN IF
NECESSARY. SKIN: WASH WITH PLENTY OF WATER. CALL PHYSICIAN IF
IRRITATION PERSISTS, REMOVE CONTAMINATED CLOTHING. INGESTION: DRINK
LARGE VOLUMES OF WATER. CALL PHYSICIAN IMMEDIATELY. DO NOT GIVE
ANYTHING TO AN UNCONSCIOUS PERSON. INHILATION:REMOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE TO BOILING
Extinguishing Media:WATER SPRAY OR DRY CHEMICAL. USE WATER SPRAY TO
COOL FIRE EXPOSED CONTAINERS.
Fire Fighting Procedures:DO NOT ENTER CONFINED FIRE SPACES WITHOUT
PROPER PROTECTIVE CLOTHING AND SELF-CONTAINED AIR SUPPLY.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:NORMAL PICK UP WITH MOP OR WET VACUUM. RINSE
FLOOR THOROUGHLY WITH WATER.
Neutralizing Agent:NOT PROVIDED.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE ALL PRODUCT ACCORDING TO GOOD
MANUFACTURING PRACTICES.KEEP CONTAINER CLOSED WHEN NOT IN USE.WASH
AFTER HANDLING.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL CONDITION OF USE.
Ventilation:LOCAL
Other Protective Equipment:NONE REQUIRED UNDER NORMAL USE.
Work Hygienic Practices:AVOID CONTACT WITH EYES OR SKIN.DO NOT INGEST.
USE ADEQUATE VENTILATION.
Supplemental Safety and Health
NONE **BOX OF 12 @ 1 QUART, READY TO USE.
================== Physical/Chemical Properties ==================
HCC:B3
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:=100.C, 212.F
Vapor Density:APPROX. 1
Spec Gravity:1.04APPROXIMATELY
VOC Pounds/Gallon:16
pH:11.5
Solubility in Water:COMPLETE
Appearance and Odor:ORANGE COLOR LIQUID, CITRUS ODOR
Percent Volatiles by Volume:NOT PROVIDED
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NOT PROVIDED.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
UNIDENTIFIED ORGANIC VAPORS MAY BE FORMED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN AN APPROVED WASTE FACILITY
ACCORDINGTO FEDERAL ,STATE,AND LOCAL REGULATIONS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:GF/5060/15A/BR
CAGE:07294
CAGE:07294
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR.AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UNC ONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
=======================================================
NIIN: 00-527-2623
Product ID: ENAMEL FLOOR & DECK
Cage: GO423
=======================================================
Contractor Summary
=======================================================
Cage: 35178
Cage: GO423
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: ENAMEL
Specification Number: TTE-487E
Unit of Issue: GL
UI Container Qty: 4
=======================================================
Ingredients
=======================================================
Cas: 8052-41-3
RTECS #: WJ8925000
% Wt: 24.5
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 100 PPM
------------------------------
Cas: 64742-95-6
% Wt: 1.3
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 50 PPM
------------------------------
Cas: 107-98-2
RTECS #: UB7700000
% Wt: 1.3
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 100 PPM
------------------------------
% Wt: 8.9
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYE: IRRIT. SKIN: IRRIT. INHAL: HARMFUL. BRAIN/NERVOUS
SYSTEM (DIZZY, HEADACHE, NAUSEA). NOSE/THROAT IRRIT. INGEST: GI IRRIT.
CHRONIC: PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE. HARMFUL, FATAL.
Medical Cond Aggravated By Exposure: PRE-EXISTING RESPIRATORY CONDITIONS.
First Aid: EYE: FLUSH W/WATER FOR 15 MINUTES. SKIN: WASH W/SOAP & WATER.
REMOVE CONTAM CLOTHES. INHAL: REMOVE TO FRESH AIR. RESTORE BREATHING. INGEST:
DRINK 2 GLASSES OF WATER. DONT INDUCE VOMIT. CALL POISON CON TROL. IN ALL
CASES, GET IMMEDIATE MEDICAL ATTENTION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE IGNIT SOURCES. PROVIDE VENTILATION. USE SCOOP
ON LARGE SPILLS & ABSORBENT MATERIAL ON SMALL SPILLS. USE RESPIRATORY
PROTECTION. FLUSH AREA W/WATER. HOLD CLEAN-UP MATERIALS FOR PROPER DISPOSAL.
Waste Disposal Methods: IN ACCORDANCE W/FEDERAL, STATE & LOCAL REGULATIONS.
BEFORE CLEAN-UP REFER TO HAZARD CAUTION INFORMATION IN OTHER SECTIONS.
Handling And Storage Precautions: STORE IN A WELL-VENT AREA & AWAY FROM
HEAT, IGNIT SOURCES. DONT STORE >100F. KEEP CONTAINER CLOSED &
UPRIGHT. DONT PUNCTURE, DRAG, SLIDE CONTAINERS.
Other Precautions: DRUMS SHOULD BE GROUNDED WHEN POURING. RESTRICT FREE FALL OF
LIQUID TO A FEW INCHES TO AVOID GENERATION OF STATIC CHARGE.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: 108F,42C
Lower Limits: 1.1
Extinguishing Media: FOAM, CO2, DRY CHEMICAL, WATER FOG. USE ANY CLASS B
APPROVED FIRE EXTINGUISHER.
Fire Fighting Procedures: KEEP CONTAINER TIGHTLY CLOSED. REMOVE FROM IGNIT
SOURCES. IN EXTREME HEAT CLOSED CONTAINERS EXPLODE. APPLICATION TO HOT
SURFACES REQUIRES SPECIAL PRECAUTIONS.
Unusual Fire/Explosion Hazard: WATER SPRAY MAY BE INEFFECTIVE. WATER FOG
NOZZLES PREFERRED. USE WATER TO COOL CONTAINERS. USE FULL PROTECTIVE
EQUIPMENT W/SCBA.
=======================================================
Control Measures
=======================================================
Respiratory Protection: UNRESTRICTED VENT: MECHANICAL FILTER TO REMOVE SOLID
PARTICLES. RESTRICTED VENT: USE CHEMICAL/MECHANICAL FILTER TO REMOVE BOTH
VAPOR & SOLIDS. NO VENT: USE AIR LINE TYPE RESPIRATOR.
Ventilation: VENT SYSTEM DESIGNED & MAINTAINED TO PROVIDE VOLUME &
PATTERN TO PREVENT CONCENTRATION IN EXCESS OF THE TLV.
Other Protective Equipment: EYE WASH STATION & SAFETY SHOWERS AVAILABLE.
Work Hygienic Practices: WASH HANDS BEFORE EATING OR USING WASHROOM. SMOKE IN
DESIGNATED AREAS ONLY.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 311 TO 390F
Vapor Density: >AIR
Evaporation Rate & Reference: SLOWER THAN ETHER
Percent Volatiles by Volume: 44.56%
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEAT & OPEN FLAME.
Materials To Avoid: OXIDIZING AGENTS.
Hazardous Decomposition Products: CARBON MONOXIDE & OTHER ORGANIC MATERIALS MAY
BE FORMED DURING COMBUSTION.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 75104
Product ID: ENAMEL FLOOR & DECK
Review Date: 03/05/1998
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: GL
Container QTY: 4
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: GJJ
Symbols: G
DOT Proper Shipping Name: FLAMMABLE LIQUIDS, N.O.S.
Hazard Class: 3
UN ID Num: UN1993
DOT Packaging Group: II
Label: FLAMMABLE LIQUID
Special Provision: T8,T31
Non Bulk Pack: 202
Bulk Pack: 242
Max Qty Pass: 5L
Max Qty Cargo: 60 L
Vessel Stow Req: B
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: HIN
IMO Proper Shipping Name: FLAMMABLE LIQUID, N.O.S. o
IMDG Page Number: 3230
UN Number: 1993
UN Hazard Class: 3.2
IMO Packaging Group: I/II
Subsidiary Risk Label: -
EMS Number: 3-07
MED First Aid Guide NUM: T
=======================================================
Detail IATA Information
=======================================================
IATA PSN BV
IATA UN ID Num: 1993
IATA Proper Shipping Name: FLAMMABLE LIQUID, N.O.S. *
IATA UN Class: 3
IATA Label: FLAMMABLE LIQUID
UN Packing Group: II
Packing Note Passenger: 305
Max Quant Pass: 5L
Max Quant Cargo: 60L
Packaging Note Cargo: 307
=======================================================
Detail AFI Information
=======================================================
AFI PSN BV
AFI Symbols: *
AFI Proper Shipping Name: FLAMMABLE LIQUIDS, N.O.S.
AFI Hazard Class: 3
AFI UN ID NUM: UN1993
AFI Packing Group: II
Special Provisions: P5
Back Pack Reference: A7.3
=======================================================
HAZCOM Label
=======================================================
Product ID: ENAMEL FLOOR & DECK
Cage: GO423
Assigned IND: Y
Company Name: LASTING PAINTS, INC.
Street: 200 S FRANKLINTOWN ROAD
Zipcode: 21223
Label Required IND: Y
Date Of Label Review: 10/12/1999
Status Code: A
Origination Code: G
Hazard And Precautions: EYE: IRRIT. SKIN: IRRIT. INHAL: HARMFUL. BRAIN/NERVOUS
SYSTEM (DIZZY, HEADACHE, NAUSEA). NOSE/THROAT IRRIT. INGEST: GI IRRIT.
CHRONIC: PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE. HARMFUL, FATAL.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:THIOKOL MC-236 BASE
Preparer's Name:DAVID B WIENCKOWSKI
CAGE:32063
CAGE:32063
============= Composition/Information on Ingredients =============
Ingred Name:LIMESTONE/CALCIUM CARBONATE
CAS:471-34-1
RTECS #:FF9335000
Fraction by Wt: 30-60%
Other REC Limits:*15 MG/M3 TOTAL PART
OSHA PEL:5 MG/M3 RESP FRACTN*
ACGIH TLV:10MG/M3 TOTAL PARTIC
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 1-5%
Other REC Limits:*10 MG/M3 TOTAL PART
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:QUARTZ (CRYSTALLINE SILICA)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 0.36%
Other REC Limits:NONE SPECIFIED
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYE: OTHER THAN MECHANICAL IRRITATION,
NO ADVERSE EFFECTS EXPECTED. SKIN: IRRITATION CAN OCCUR FOLLOWING
PROLONGED OR REPEATED CONTACT. INHALATION: UNDER NORMAL CONDITIONS
OF USE NO ADVERSE EFFECTS EX PECTED. INGESTION: CAN CAUSE NAUSEA,
VOMITING, AND GASTROINTESTINAL UPSET.
Explanation of Carcinogenicity:CRYSTALLINE SILICA:SIGNIFICANT INCIDENCE
OF ADENOCARCINOMAS & SQUAMOUS CELL CARCINOMAS OF LUNG INDUCE IN
RATS EXPOSED.
Effects of Overexposure:DEPENDING ON ROUTE, FREQUENCY & DURATION OF
EXPOSURE TOXICITY MAY EFFECT THE FOLLOWING ORGANS OR SYSTEMS.
RESPIRATORY SYSTEM, IMMUNE SYSTEM (E.G. ALLERGIC REACTIONS).
Medical Cond Aggravated by Exposure:EXPOSURE TO THIS PRODUCT IS NOT
EXPECTED TO CONTRIBUTE TO, WORSEN, OR AGGRAVATE ANY EXISTING
MEDICAL CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WATER 15 MIN.IF IRRIT,SEE DR. SKIN:REMOVE CONTAM
CLOTH & SHOES.WASH CONTAM SKIN W/SOAP & WATER.IF IRRIT, SEE DR.WASH
CONTAM CLOTH SEPARATELY BEFORE REUSE.INHAL:REMOVE TO FRESH AIR. GET
IMM ED MED AID.IF NO BREATH,GIVE ARTIF RESP(MOUTH TO
MOUTH).INGEST:GET MED AID,UNLESS ADVISED,INDUCE VOMIT (IPECAC W/2
GLASSES WATER/FINGER DOWN THROAT).NOTHING BY MOUTH TO
UNCONSCIOUS,DROWSY,NO GAG REFL
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>200F,>93C
Extinguishing Media:CLASS A HAZARD: HALOGENATED AGENTS, FOAM, STREAM OR
WATER FOG.
Fire Fighting Procedures:FIRE FIGHTERS & OTHER WHO MAY BE EXPOSED TO
PRODUCTS OF COMBUSTION SHOULD BE EQUIPPED W/NIOSH POSITIVE PRESSURE
SCBA & FULL PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:SHOVEL OR VACUUM SPILLED PRODUCTS & PLACE IN
CLOSED CONTAINERS FOR FURTHER HANDLING & DISPOSAL. IN AREAS WITH
INADEQUATE VENTILATION OR IN ENCLOSED SPACES, USE A SELF-CONTAINED
BREATHING APPARATUS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, VENTED AREA. NO
SPECIAL PRECAUTION NEEDED. FOLLOW GOOD MFR & HANDLING PRACTICES.
CONTAINER CAN BE HAZARDOUS WHEN EMPTY (RESIDUE).
Other Precautions:CONTAINER CAN BE HAZARDOUS WHEN EMPTY BECAUSE IT CAN
RETAIN PRODUCT RESIDUES, THEREFORE, DO NOT REUSE CONTAINER FOR
FOOD, CLOTHING, OR PRODUCTS FOR HUMAN OR ANIMAL CONSUMPTION OR
WHERE SKIN CONTACT MA Y OCCUR.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT USUALLY REQUIRED. ABOVE EXPOSURE LIMITS,
WEAR NIOSH/MSHA EQUIPMENT. SEE RESPIRATOR MFR FOR APPROPRIATE TYPE
EQUIPMENT. OBSERVE RESPIRATOR USE LIMITS SPECIFIED BY NIOSH/MSHA OR
MFR. SCBA/SUPPLIED A IR RESPIRATOR FOR HIGH CONCENTRATIONS.
Ventilation:KEEP BELOW PEL/TLV. GENERAL (DILUTION) VENT MAY BE
ACCEPTABLE. LOCAL EXHAUST VENT RECOMMENDED WHEN VAPOR/MIST
RELEASED.
Other Protective Equipment:AN EYE WASH FACILITY SHOULD BE READILY
AVAILABLE.
Work Hygienic Practices:WASH AFTER HANDLING, BEFORE EATING,DRINKING,
SMOKING,USING RESTRM. CLEAN & DRY CONTAMINATED CLOTHES & SHOES
BEFORE REUSE
Supplemental Safety and Health
KEY1:N1. THIS PRODUCT CONTAINS LESS THAN 0.1% OF FORMALDEHYDE, WHICH
CAN ACCUMULATE IN THE HEADSPACE OF SEALED CONTAINERS, MAINTIAN
ADEQUATE VENTILATION IF THE AIRBORNE CONCENTRATION CAN EXCEED
ESTABL ISHED LIMITS (OSHA PEL 1 PPM; STEL 2 PPM; ACGIH TLV 1 PPM,
STEL 2 PPM) APPROPRIATE RESPIRATORY EQUIPMENT SHOULD BE WORN.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.61
Viscosity:9000-14000 P
Solubility in Water:INSOLUBLE
Appearance and Odor:LIGHT COLORED, OFF WHITE PASTE, SULFIDE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Hazardous Decomposition Products:PHENOLICS, OXIDES OF NITROGEN, OXIDES
OF SULFUR, SMOKE, SOOT, TOXIC FUMES (CO & CO2), HYDROGEN SULFIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T FLUSH TO SEWER, STREAM, OTHER WATER
BODIES. IF DISCARDED IN ORIGINAL UNUSED FORM, MANAGE AT AUTHORIZED
FACILITY, IN COMPLIANCE W/FED, STATE & LOCAL REGULATIONS. CONTACT
GOVERNMENTAL AGENCIES FOR GUIDANCE. 1)RECYCLE. 2)INCINERATE.
3)TREAT.
| 1 | gloves_mandatory |
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.