text
stringlengths 542
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:ZL-17C ZYGLO WATER WASHABLE PENETRANT 55 GAL
CAGE:37141
CAGE:37676
CAGE:37141
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL, WHITE; (WHITE MINERAL OIL)
CAS:8042-47-5
RTECS #:PY8047000
Fraction by Wt: 75%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:KEROSENE
CAS:8008-20-6
RTECS #:OA5500000
Fraction by Wt: 10%
OSHA PEL:100 MG/M3
ACGIH TLV:N/K
Ingred Name:PROPANE, 2-METHYL-; (ISOBUTANE)
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 30%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: DIZZINESS, NAUSEA. SKIN:
IRRITATES SKIN BY DISSOLVING SKIN OILS. EYE: IRRITATING TO EYES.
INGEST: GASTRIC UPSET.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. SKIN: WASH OFF PROMPTLY WITH SOAP
AND WATER. USE SOOTHING LOTIONS. EYE: RINSE COPIOUSLY WITH WATER
FOR AT LEAST 15 MIN. INGEST: DO NOT INDUCE VOMITING UNLESS UNDER
CONTROL OF PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F,>93C
Lower Limits:1%
Upper Limits:6%
Extinguishing Media:CARBON DIOXIDE, FOAM.
Fire Fighting Procedures:KEEP CONTAINERS COOL WITH WATER SPRAY. DO NOT
SPRAY WATER ON BURNING ZL-17C. WEAR NIOSH/MSHA APPROVED SCBA AND
FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:AEROSOL CANS MAY BURST IF HEATED ABOVE
130F, ADDING TO ANY EXISTING FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID REPEATED OR PROLONGED CONTACT
WITH SKIN. DO NOT GET IN EYES. AVOID BREATHING SPRAY MIST.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:VENTILATION RATE SUFFICIENT TO KEEP VAPORS AND SPRAY MISTS
BELOW THE OSHA PELS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:410F,210C
Vapor Pres:0.5 @ 100F
Vapor Density:> 1
Spec Gravity:0.88
pH:NEUT
Evaporation Rate & Reference:NIL
Solubility in Water:EMULSIFIABLE
Appearance and Odor:GREEN OILY LIQUID.
Percent Volatiles by Volume:5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WHEN BURNING, SOOT, SMOKE, OXIDES OF
CARBON AND NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR SEND TO WASTE DISPOSER WHO CAN
INCINERATE IT. EMPTY OUT AEROSOL CANS BEFORE DISPOSAL. PRESSURIZED
AEROSOL CANS ARE NOT AN ACCEPTABLE WASTE. DISPOSAL MUST BE IN
ACCORDANCE WITH FEDERAL, S TATE AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DETERFENT GP, TYPE II
CAGE:LO534
CAGE:LO534
CAGE:91341
============= Composition/Information on Ingredients =============
Ingred Name:SURFACTANT
===================== Hazards Identification =====================
Effects of Overexposure:MAY CAUSE SKIN IRRITATION
======================= First Aid Measures =======================
First Aid:SKIN-WAHS WITH SOAP & WATER EYE CONTACT - FLUSH WITH WATER
FOR 15 MIN.
===================== Fire Fighting Measures =====================
Flash Point:455F,235C COC
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH AREA WITH HOT WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:NORMAL
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Ventilation:MECHANICAL
Other Protective Equipment:NONE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:300F,149C
Spec Gravity:1.059
Solubility in Water:COMPLETELY
Appearance and Odor:VISCOUS YELLOW LIQUID - MILD ODOR
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:ACCORDING TO FEDERAL STATE AND LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:4701 BATTLESHIP GRAY CHEM RESIST URETHANE,A
CAGE:D0218
CAGE:59500
CAGE:D0218
============= Composition/Information on Ingredients =============
Ingred Name:2-ETHOXYETHYL ACETATE (CELLOSOLVE ACETATE) (EGEEA)
CAS:111-15-9
RTECS #:KK8225000
Fraction by Wt: 30%
OSHA PEL:S,100 PPM
ACGIH TLV:S, 5 PPM; 9192
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 2%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL N-AMYL KETONE
CAS:110-43-0
RTECS #:MJ5075000
Fraction by Wt: 10%
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9192
Ingred Name:POLYESTER
Fraction by Wt: 25%
===================== Hazards Identification =====================
Effects of Overexposure:INH:ANESTH.IRRIT RESP TRACT OR ACUTE CNS
DEPRESS W/HDCH,DIZ,STAG,UNCON.SEV EYE IRRIT;DRY SKIN
======================= First Aid Measures =======================
First Aid:INH:REMOVE TO RESH AIR.APPLY ARTIF RESP IR NEC.KEEP WARM &
QUIET. CALL MD.SKIN:WASH AREAS W/SOAP & WATER.REMOVE CONTAM
CLOTHING.EYE:FLUSH IMMED W/WATER FOR 15 MIN.CALL DR.
===================== Fire Fighting Measures =====================
Flash Point:>100F SCC
Extinguishing Media:NFPA CLASS B EXTING,CO*2,DRY CHEMICAL,FOAM
Fire Fighting Procedures:USE WATER FOG TO COOL EXPOS CANS & PREVENT
PRESSURE BUILDUP
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY XCLSD.KEEP FRM
IGNIT SOURCES.CLSD CAN MAY EXPLO FRM EXTREM HEAT.(SUP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT.AVOID BRTHNG
VAPORS.VENTIL AREA.REMOVE W/INERT ABSORBENT.WIPE UP W/SOLENT TO
REMOVE FINAL RESIDUE.OBSERVE SPECIAL PROTECTION INFO.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY PLACE.STORE LG QTY
INBUILDINGS DESIGNED & PROTECTED FOR STORAGE OF NFPA CLASS II
COMBUST LIQ.
Other Precautions:DO NOT TAKE INTERNALLY.AVOID PROLONGED CONTACT
W/SKIN;CONTAM CLOTHING SHOULD BE REMOVED IMMED.GROUND CONTAINER
WHEN POURING.AVOID FREE FALL OF LIQ IN EXCESS OF A FEW IN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD CHEM RESP FOR ORGANIC VAPORS
AS REQD
Ventilation:GEN DILTN OF LOC EXHST IN VOL & PATTERN TO KEEP BELOW TLV
Supplemental Safety and Health
DO NOT APPLY PRODUCT TO HOT SURFACES.PART A OF A TWO PART PRODUCT.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:281-320F
Vapor Density:>1.0
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:63
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CAN REACT W/STRONG OXIDIZING MATERIALS
Hazardous Decomposition Products:CO,CO*2
==================== Disposal Considerations ====================
Waste Disposal Methods:MFR RECM INCIN IN APPRVD FACILITY.DO NOT INCIN
CLSD CONTAINERS.DISPOSE IAW FED,STATE & LOCAL CODES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DOW CORNING 5 COMPOUND
CAGE:5D028
CAGE:58149
CAGE:5D028
CAGE:71984
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, AMORPHOUS OR SILICA GEL
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:2,6-CIS-DIPHENYLHEXAMETHYLCYCLOTETRASILOXANE
CAS:33204-76-1
RTECS #:GZ4390000
Fraction by Wt: <0.1%
Other REC Limits:TWA 20 UGM/M3 (DOW)
Ingred Name:PHENYLHEPTAMETHYLCYCLOTETRASILOXANE
CAS:10448-09-6
RTECS #:GZ4392000
Fraction by Wt: <0.1%
Other REC Limits:TWA 200 UGM/M3 (DOW)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: DIRECT EYE CONTACT MAY CAUSE
TEMPORARY DISCOMFORT. NO KNOWN EFFECTS ON SKIN CONTACT. NO KNOWN
ILL EFFECTS IF VAPOR INHALED. SMALL AMOUNTS TRANSFERRED TO MOUTH BY
FINGERS SHOULD NOT INJURE. INGE STING LARGE AMOUNTS MAY CAUSE
DIGESTIVEDISCOMFORT. CHRONIC: NONE KNOWN.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:EYES-TEMPORARY DISCOMFORT, REDNESS, DRYNESS.
SKIN-NONE KNOWN. INHALED-NONE KNOWN. INGESTED-POSSIBLE DIGESTIVE
DISCOMFORT.
Medical Cond Aggravated by Exposure:NOTE: THIS COMPOUND CONTAINS LOW
LEVELS OF (INGREDIENTS 2 & 3) WHICH ARE ESTROGEN-LIKE COMPOUNDS.
ESTROGENS ARE HORMONES WHICH AFFECT THE REPRODUCTIVE SYSTEM.
======================= First Aid Measures =======================
First Aid:EYES-IMMEDIATELY FLUSH WITH WATER. SKIN-NO FIRST AID SHOULD
BE NEEDED. INHALED-NO FIRST AID SHOULD BE NEEDED. INGESTED-NO FIRST
AID SHOULD BE NEEDED. NOTE: TREAT SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>213F,>101C
Extinguishing Media:WATER FOG, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:IF LARGE AMOUNTS INVOLVED-EVACUATE. WEAR
SELF-CONTAINED BREATHING APPARATUS AND FULL FIRE FIGHTER'S
PROTECTIVE GEAR. USE WATER TO COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:MOP WITH MILD CAUSTIC/BASIC MATERIAL OR USE
HIGH PRESSURE STEAM. OBSERVE ALL SAFETY PRECAUTIONS.
Neutralizing Agent:MILD CAUSTIC SOLUTION.
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL PRECAUTIONS. USE REASONABLE
CARE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:GENERAL-MECHANICAL RECOMMENDED.
Other Protective Equipment:AS REQUIRED
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
TRACES OF BENZENE MAY FORM IF HEATED IN AIR ABOVE 300F (149C). PROVIDE
VENTILATION TO CONTROL VAPOR EXPOSURE WITHIN INHALATION GUIDELINES
WHEN AHNDLING AT ELEVATED TEMPERATURES. REVIEW OSHA BENZENE R
EGULATION FOR DETAILED INFORMATION ON SAFE HANDLING REQUIREMENTS.
================== Physical/Chemical Properties ==================
HCC:V7
Spec Gravity:1.0
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TRANSLUSCENT, WHITE GREASE; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL CAN CAUSE A REACTION.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:SILICON DIOXIDE, CARBON OXIDES, TRACES
OF INCOMPLETELY BURNED CARBON COMPOUNDS; FORMALDEHYDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL ENVIRONMENTAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:SULFURIC ACID, A300S 500
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:SULFURIC ACID
CAS:7664-93-9
RTECS #:WS5600000
Minumum % Wt:95.
Maxumum % Wt:98.
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
ACGIH STEL:3 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT): 2140 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CAUSES SEVERE EYE BURNS. MAY
CAUSE IRREVERSIBLE EYE INJURY. SKIN: CAUSES SKIN BURNS. INGESTION:
MAY CAUSE SEVERE AND PERMANENT DAMAGE TO THE DIGESTIVE TRACT.
CAUSES GASTROINTESTINAL TRACT BURNS . INHALATION: HARMFUL IF
INHALED, MAY CAUSE SEVERE IRRITATION OF THE RESPIRATORY TRACT WITH
SORE THROAT, COUGHING, SHORTNESS OF BREATH AND DELAYED LUNG EDEMA.
CAUSES CHEMICAL BURNS TO THE RESPIRATORY TRACT. CHRONIC: PROLONGED
OR REPEATED INHALATION MAY CAUSE NOSEBLEED, NASAL CONGESTION,
EROSION OF THE TEETH, PERFORATION OF THE NASAL SEPTUM, CHEST PAIN
AND BRONCHITIS. PROLONGED OR REPEATED EYE CONT ACT MAY CAUSE CONJ.
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF H*2O FOR AT LEAST 15 MIN, OCCAS
LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. DO NOT ALLOW VICTIM
TO RUB/KEEP EYES CLOSED. SKIN: GET MED AID IMMED. FLUSH SKIN
W/PLENTY OF SOAP & H*2O FOR AT LEAST 15 MIN WHILE REMOVING CONTAMD
CLTHG & SHOES. SPEEDY ACTION IS CRITICAL! INGEST: DO NOT INDUCE
VOMIT. IF VICTIM IS CONSCIOUS & ALERT, GIVE 2-4 CUPFULS OF
MILK/H*2O. NEVER GIVE ANY THING BY MOUTH TO UNCON PERS. GET MED AID
IMMED. INHAL: GET MED AID IMMED. REMOVE FROM EXPOS TO FRESH AIR
IMMED. IF NOT BRTHG, GIVE ARTF RESP. IF BREATHING IS DIFFICULT,
GIVE OXYGEN. DO NOT USE MOUTH- TO-MOUTH RESPIRATION. (SUPDAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:USE CARBON DIOXIDE OR DRY CHEMICAL. DO NOT GET
WATER INSIDE CONTAINERS. COOL CONTAINERS WITH FLOODING QUANTITIES
OF WATER UNTIL WELL AFTER FIRE IS OUT.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROT EQUIP .
STRONG OXIDIZER. CONTACT W/COMBUSTIBLE MATLS MAY CAUSE A FIRE.
CONTACT W/H*2O CAN CAUSE VIOLENT LIBERATION OF HEAT & SPLATTERING
OF THE MATERIAL. CONT ACT W/ METALS MAY EVOLVE FLAMMABLE HYDROGEN
GAS. CONTAINERS MAY EXPLODE WHEN HEATED OR IF CONTAMINATED W/H*2O.
Unusual Fire/Explosion Hazard:HEALTH: 3; FLAMMABILITY: 0; REACTIVITY:
2.
================== Accidental Release Measures ==================
Spill Release Procedures:GENERAL INFORMATION: USE PROPER PERSONAL
PROTECTIVE EQUIPMENT AS INDICATED IN SECTION 8. SPILLS/LEAKS:
CLEAN UP SPILLS IMMEDIATELY, OBSERVING PRECAUTIONS IN THE
PROTECTIVE EQUIPMENT SECTION. COVER WI TH SAND, DRY LIME OR SODA
ASH AND PLACE IN A CLOSED CONTAINER FOR DISPOSAL. USE WATER SPRAY
TO REDUCE VAPORS, DO NOT PUT WATER DIRECTLY ON LEAK, SPILL AREA OR
INSIDE CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLING: DO NOT GET IN EYES, ON SKIN,
OR ON CLOTHING. KEEP CONTAINER TIGHTLY CLOSED. DO NOT INGEST OR
INHALE. DO NOT ALLOW CONTACT WITH WATER. USE ONLY IN A CHEMICAL
FUME HOOD. STORAGE: DO NOT STORE NEAR COMBUSTIBLE MATERIALS.
Other Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE. STORE IN A
COOL, DRY, WELL-VENTILATED AREA AWAY FROM INCOMPATIBLE SUBSTANCES.
DO NOT STORE NEAR ALKALINE SUBSTANCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
29CFR 1910.134 OR EUROPEAN STANDARD EN 149. ALWAYS USE A NIOSH OR
EUROPEAN STANDARD EN 166 APPROVED RESPIRATOR WHEN NECESSARY.
Ventilation:USE PROCESS ENCLOSURE, LOCAL EXHAUST VENTILATION, OR OTHER
ENGINEERING CONTROLS TO CONTROL AIRBORNE LEVELS BELOW RECOMMENDED
EXPOSURE LIMITS.
FACESHIELD .
Other Protective Equipment:ANSI APPROVED EYE WASH AND DELUGE SHOWER .
WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
Supplemental Safety and Health
FIRST AID PROC: NOTES TO MD: TREAT SYMPTOMATICALLY & SUPPORTIVELY.
PHYSICAL DATA: MOLECULAR FORUMLA: H2SO4. MOLECULAR WEIGHT: 98.0716.
MATLS TO AVOID: AMMONIUM IRON (III) SULFATE DODECAHYDRATE, AMMONI
UM TRIPERCHROMATE, ANILINE + GLYCEROL + NITROBENZENE, BENZYL
ALCOHOL, BROMATES + METALS, TERT-BUTYL-M- (OTHER INFO)
================== Physical/Chemical Properties ==================
Boiling Pt:=290.C, 554.F
Melt/Freeze Pt:=10.3C, 50.5F
Vapor Pres:<0.00120 MM HG
Vapor Density:1.2 KG/M3
Spec Gravity:1.841
pH:0.3 (IN SOLN)
Viscosity:NEGLIBLE
Evaporation Rate & Reference:SLOWER THAN ETHER.
Solubility in Water:SOL IN WATER & ETHANOL
Appearance and Odor:COLOURLESS LIQUID; ODORLESS.
Percent Volatiles by Volume:NEGLIBLE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACETIC ANHYDRIDE, ACETONE CYANHYDRIN, ACETONE + NITRIC ACID, ACETONE +
POTASSIUM DICHROMATE, ACETONITRILE + SULFUR TRIOXIDE, ACROLEIN,
ACRYLONITRILE, ALCOHOLS + HYDROGEN PEROXIDE, ALLYL ALCOHOL, ALLYL
CHLORIDE, 2-AMINOETHAN
Stability Condition to Avoid:INCOMPATIBLE MATERIALS, CONTACT WITH
WATER, METALS, EXCESS HEAT, COMBUSTIBLE MATERIALS, ORGANIC
MATERIALS, OXIDIZERS, AMINES, BASED.
Hazardous Decomposition Products:OXIDES OF SULFUR.
Conditions to Avoid Polymerization:HAS NOT BEEN REPORTED.
=================== Toxicological Information===================
Toxicological Information:RTECS#: CAS# 7664-93-9 WS5600000. LD50/LC50:
CAS# 7664-93-9: INHALATION, MOUSE: LC50=320 MG/M3/2H; INHAL, RAT:
LC5=510 MG/M3/2H. CARCINOGENICITY: SULFURIC ACID: ACGIH: (
CONTAINED IN STRONG INORGANIC ACID MISTS): A2 - SUSPECTED. OSHA:
SELECT CARCINOGEN. IARC: GROUP 1 CARCINOGEN. WORKERS EXPOSED TO
INDUSTRIAL SULFURIC ACID MIST SHOWED A STATISTICAL INCREASE IN
LARYNGEAL CANCER. THIS DATA SUGGESTS A POSSIBLE RELATIONSHIP
BETWEEN CARCINOGENISIS & INHALATION OF SULFURIC ACID MIST.
TERATOGENICITY, REPRODUCTIVE EFFECTS, NEUROTOXICITY, MUTAGENICITY &
OTHER STUDIES: NO DATA AVAILABLE.
===================== Ecological Information =====================
Ecological:ECOTOXICITY: SULFURIC ACID IS HARMFUL TO AQUATIC LIFE IN
VERY LOW CONCENTRATIONS. IT MAY BE DANGEROUS IF IT ENTERS H*2O
INTAKES. THE AQUATIC TOX FOR BLUEGILL IN FRESH H*2O WAS 24.5 PPM/24
HR, WHICH WA S LETHAL. ENVIRONMENTAL FATE, PHYSICAL/CHEM & OTHER:
NOT AVAIL CLEAN AIR ACT: THIS MATL DOES NOT CONTAIN ANY HAZ AIR
POLLUTANTS. THIS MATL DOES NOT CONTAIN ANY CLASS , OZONE DEPLETORS.
THIS MATL DOES NOT CONTAIN & CLASS 2 OZONE DEPLETORS. CLEAN WATER
ACT: CAS# 7664-93-9 IS LISTED AS HAZ SUBSTANCE UNDER CWA. NONE OF
CHEMS IN THIS PROD ARE LISTED AS PRIORITY POLLUTANTS UNDER CWA.
NONE OF CHEMS IN TH IS PRODUCT ARE LISTED AS TOX POLLUTANTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE, AND LOCAL REGULATIONS. RCRA D-SERIES MAXIMUM CONCENTRATION
OF CONTAMINANTS, RCRA D-SERIES CHRONIC TOXICITY REFERENCE LEVELS,
RCRA F-SERIES, RCRA P-SERIES, RCRA U-SERIES. NOT LISTED AS A
MATERIAL BANNED FROM LAND DISPOSAL ACCORDING TO RCRA.
=================== MSDS Transport Information ===================
Transport Information:US DOT: SHIPPING NAME: SULFURIC ACID. HAZARD
CLASS: 8, UN NUMBER: UN1830 PACKING GROUP: II. IMO, IATA & RID/ADR:
NO INFORMATION AVAILABLE. CANADIAN TDG: SHIPPING NAME: SUFLURIC
ACID. HAZARD CLASS: 8(9 .2). UN NUMBER: UN1830.
===================== Regulatory Information =====================
SARA Title III Information:SECTION 302 (RQ): CAS # 7664-93-9: FINAL RQ
= 1000 POUNDS (454 KG). SECTION 302 (TPQ):CAS # 7664-93-9: TPQ
1000 POUNDS; RQ + 1000 POUNDS. SARA CODES: CAS # 7664-93-9: ACUTE,
CHRONIC, REACTIVE. SECTIO N 313: THIS MATERIAL CONTAINS SULFURIC
ACID (CAS# 7664-93-9, 95 98 0%), WHICH IS SUBJECT TO THE REPORTING
REQUIREMTNTS OF SECTION 313 OF SARA TITILE III AND 40 CFR PART 373.
Federal Regulatory Information:TSCA: CAS# 7664-93-9 IS LISTED ON THE
TSCA INVENTORY. HEALTH & SAFETY REPORTING LIST: NONE OF THE
CHEMICALS ARE ON THE HEALTH & SAFETY REPORTING LIST. CHEMICAL TEST
RULES: NONE OF THE CHEMICLS ALS INTHIS PRODUCT ARE UNDER A
CHEMICAL TEST RULE. SECTION 12B: NONE OF THE CHEMICALS ARE LISTED
UNDER TSCA SECTION 12B. TSCA SIGNIFICANT NEW USE RULE: NONE OF THE
CHEMICALS IN THIS MATERIAL HAVE A SNUR CHE MICAL UNDER TSCA.
State Regulatory Information:SULFURIC ACID CAN BE FOUND ON THE
FOLLOWING STATE RIGHT TO KNOW LISTS: CALIFORNIA, NEW JERSEY,
FLORIDA, PENNSYLVANIA, MINNESOTA, MASSACHUSETTS. CALIFORNIA NO
SIGNIFICANT RISK LEVEL: NONE OF THE CHEMIC ALS IN THIS PRODUCT ARE
LISTED.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ISOCYANATE ACTIVATOR/HARDENER 792S
CAGE:19898
CAGE:90227
CAGE:19898
============= Composition/Information on Ingredients =============
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL ACETATE (SARA III)
CAS:141-78-6
RTECS #:AH5425000
OSHA PEL:400 PPM
ACGIH TLV:400 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:AROMATIC HYDROCARBONS (VAPOR PRESSURE = 5)
ACGIH TLV:50 PPM
Ingred Name:POLYMERIC HEXAMETHYLENE DIISOCYANATE
RTECS #:MD1740000
Fraction by Wt: <0.2%
===================== Hazards Identification =====================
Effects of Overexposure:NOSE/THROAT IRRITATION. HEADACHE, DIZZINESS,
NAUSEA, STAGGERING GAIT, CONFUSION, UNCONSCIOUSNESS
======================= First Aid Measures =======================
First Aid:IN CASE OF EYE CONTACT, IMMEDIATELY FLUSH W/PLENTY OF WATER
FOR AT LEAST 15 MINUTES; CALL A PHYSICIAN. IN CASE OF SKIN CONTACT
WASH W/SOAP & WATER. IF IRRITATION OCCURS, CONTACT A PHYSICIAN. IF
AFFECT ED BY INHALATION OF VAPOR, REMOVE TO FRESH AIR
===================== Fire Fighting Measures =====================
Flash Point:20-73F (CC)
Lower Limits:1.1%
Upper Limits:14%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR SCBA. WATER COOL CONTAINERS/PREVENT
PRESSURE BUILD UP
Unusual Fire/Explosion Hazard:FINE MISTS OR SPRAYS MAY BE FLAMMABLE AT
TEMPERATURES BELOW THE FLASH POINT.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE SOURCES OF IGNITION.
PREVENT SKIN CONTACT AND BREATHING OF VAR. CONFINE AND REMOVE WITH
INERT ABSORBANT.
======================Handling and Storage ======================
Handling and Storage Precautions:OBSERVE LABEL PRECAUTIONS. KEEP AWAY
FROM HEAT, SPARKS & FLAME. CLOSE CONTAINER AFTER EACH USEGROUND
CONTAINERS WHEN POURING.
Other Precautions:WASH THOROUGHLY AFTER HANDLING & BEFORE EATING OR
SMOKING. DON'T STORE ABOVE 120F. DON'T SAND/FLAME CUT/BRAZE OR WELD
DRY COING W/OUT A NIOSH/MSHA APPROVED RESP/APPROPRIATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Ventilation:PROVIDE VENTILATION TO KEEP BELOW TLV
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:168-401F
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT
Percent Volatiles by Volume:72.9
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE REASONABLE FORESEEABLE
Hazardous Decomposition Products:CO, CO2, SMOKE
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T ALLOW MATERIAL TO CONTAMINATE GROUND WATER
SYSTEMS. INCINERATE ABSORBED MATERIAL IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REQUIREMENTS. DON'T INCINERATE IN CLOSED
CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MAGNESIUM CARBONATE BASIC
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:ING 13:EXPOSURE INFORMATION .
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:OCCAS LIFTING UPPER & LOWER LIDS, UNTIL NO
EVID OF CHEM REMAINS (AT LST 15-20 MINS). GET MED ATTN(ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:IMMED. INGEST:IF KIDNEYS ARE FUNCTIONING, GIVE LG
QTYS OF WATER TO DILUTE & FACILITATE REMOVAL OF (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:MAGNESIUM IONS. GET MED ATTN IMMED.
ANTIDOTE:DECISION OF ADMIN OF ANTIDOTE & ACTUAL DOSE SHOULD BE MADE
(ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:BY QUALIFIED MED PERS. MAGNESIUM CMPD POIS:WHEN
SERUM LEVEL >5 MEQ/L & PATIENT EXHIBITS SYMPS, GIVE (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:CALCIUM GLUCONATE, 10 ML OF 10% SOLN (IV) OVER
SEVERAL MINS. DOSE MAY BE RPTD ONCE; THEN LEVEL SHOULD BE (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19:CHECKED AGAIN.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:HIGH-EFFICIENCY PARTICULATE FILTER; ANY POWERED
AIR-PURIFYING RESP W/TIGHT-FITTING FACEPIECE & HIGH- (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21:EFFICIENCY PARTICULATE FILTER; ANY TYPE 'C'
SUPPLIED-AIR RESP W/FULL FACEPIECE OPERATED IN PRESS-DEMAND/ (ING
23)
RTECS #:9999999ZZ
Ingred Name:ING 22:OTHER POS PRESS MODE/WITH FULL FACEPIECE,
HELMET/HOOD OPERATED IN CONTINUOUS-FLOW MODE; ANY SCBA W/FULL (ING
24)
RTECS #:9999999ZZ
Ingred Name:ING 23:FACEPIECE OPERATED IN PRESSURE-DEMAND OR OTHER
POSITIVE PRESSURE MODE.
RTECS #:9999999ZZ
Ingred Name:MAGNESIUM CARBONATE; (MAGNESIUM CARBONATE, BASIC)
CAS:12125-28-9
Fraction by Wt: <99%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CALCIUM
CAS:7440-70-2
RTECS #:EV8040000
Fraction by Wt: <0.2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER INSOLUBLES; (WATER INSOLUBLE SUBSTANCES)
Fraction by Wt: <0.4%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SULFATE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:NITRATE
CAS:14797-55-8
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BARIUM (SARA 313)
CAS:7440-39-3
RTECS #:CQ8370000
OSHA PEL:0.5 MG/M3
ACGIH TLV:N/K
Ingred Name:LEAD (SARA 313) (CERCLA)
CAS:7439-92-1
RTECS #:OF7525000
OSHA PEL:SEE 1910.1025
ACGIH TLV:0.15 MG/M3 DUST
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CHLORIDE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ZINC (SARA 313) (CERCLA)
CAS:7440-66-6
RTECS #:ZG8600000
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:OTHER INGREDIENTS; (SUBSTANCES INSOLUBLE IN HCL)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:PRECIP OF MAGNESIUM AMMONIUM PHOSPHATE IN KIDNEYS.
NOTE:LEAD APPEARS ON NAVY LIST OF OCCUP CHEM REPRO (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:HAZS. SEEK CONSULTATION FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG & (ING
14)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:MAY CAUSE METAL FUME FEVER
W/COUGH, HDCH, FEVER, CHILLS, SNEEZING, NAUS, VOMIT, DYSP, CHEST
PAIN & LEUKOCYTOSIS. SKIN/EYE CONT:MAY BE IRRITATING. INGEST:SOME
MAGNESIUM SALTS MAY CAUSE PURG ING W/VOMIT & WATERY DIARR. SYSTEMIC
EFTS ARE ORDINARILY ABSENT SINCE NORMAL KIDNEY IS ABLE TO REMOVE
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:MAGNESIUM ION MORE RAPIDLY THAN IT CAN
BE ABSORBED FROM GI TRACT. IN CASES OF KIDNEY IMPAIRMENT, MUCOSAL
IRRIT & ABSORPTION OCCUR, CNS DEPRESS, AREFLEXIA, RESP CONGESTION &
DEATH FROM RESP PA RAL MAY OCCUR. CHRONIC:INHAL:FINE METALLIC DUSTS
HAVE CAUSED IRRIT & COUGH. SOME INVESTIGATORS HAVE REPORTED A
(SUPDAT)
Medical Cond Aggravated by Exposure:PERSONS W/KIDNEY IMPAIRMENT MAY BE
AT AN INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOS AREA TO FRESH AIR IMMED. IF BRTHG
STOPPED, PERFORM ARTF RESP. KEEP PERS WARM & AT REST. TREAT
SYMPTOMATICALLY & SUPPORTIVELY. GET MED ATTN IMMED. SKIN:REMOVE
CONTAM CLTHG & SHO ES IMMED. WASH AFFECTED AREA W/SOAP OR MILD
DETERGENT & LG AMTS OF WATER UNTIL NO EVID OF CHEM REMAINS(APPROX
15-20 MINS). GET MED ATTN IMMED. EYES:WASH IMMED W/LG AMTS OF
WATER/NORMAL SALINE,(ING 15)
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, WATER SPRAY OR
REGULAR FOAM. FOR LARGER FIRES, USE WATER SPRAY, FOG OR REGULAR
FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . NO ACUTE HAZARD. MOVE CNTNR FROM FIRE AREA IF POSSIBLE.
AVOID BREATHING VAPORS/DUSTS; KEEP UPWIND.
Unusual Fire/Explosion Hazard:NEGLIGIBLE FIRE HAZARD WHEN EXPOSED TO
HEAT OR FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP & PLACE IN SUITABLE CLEAN, DRY
CONTAINERS FOR RECLAMATION OR LATER DISPOSAL. DO NOT FLUSH SPILLED
MATERIAL INTO SEWER. KEEP UNNECESSARY PEOPLE AWAY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:OBSERVE ALL FEDERAL, STATE & LOCAL
REGULATIONS WHEN STORING THIS SUBSTANCE. FOR ASSISTANCE, CONTACT
THE DISTRICT DIRECTOR OF THE EPA.
Other Precautions:STORE AWAY FROM INCOMPATIBLE SUBSTANCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SPECIFIC RESP SELECTED MUST BE BASED ON CONTAM
LEVELS FOUND IN WORK PLACE & SPECIFIC OPERATION, MUST NOT EXCEED
WORKING LIMS OF RESP & BE NIOSH APPRVD: ANY DUST & MIST RESP W/FULL
FACEPIECE; ANY AIR-P URIFYING FULL FACEPIECE RESP W/ (ING 21)
Ventilation:PROVIDE LOCAL EXHAUST OR PROCESS ENCLOSURE VENTILATION
SYSTEM.
Other Protective Equipment:ANSI APPRVD EYE WASH FOUNTAIN & DELUGE
SHOWER . WEAR PROT (IMPERVIOUS) CLTHG & EQUIP TO PREVENT SKIN
CONTACT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PH:SLIGHTLY ALKALINE. EFTS OF OVEREXP:HIGHER INCIDENCE OF DIGEST
DISORDERS IN MAGNESIUM PLANT WORKERS & SUGGEST THAT RELATIONSHIP
MAY EXIST BTWN MAGNESIUM ABSORPTION & GASTRODUODENAL ULCERS.
INGEST:RP TD INGEST MAY CAUSE IRON DEFICIENCY. LONG-TERM USE OF
MAGNESIUM CNTNG ANTACIDS HAS CAUSED RENAL FAILURE FROM (ING 12)
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:1292F,700C
pH:SUPDAT
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE RHOMBIC CRYSTALS; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, FORMALDEHYDE:REACTS, RELEASING CARBON DIOXIDE GAS WHICH MAY
CAUSE PRESSURE INCR/EXPLO IF IN CLOSED CONTAINER.
Stability Condition to Avoid:STABLE UNDER NORMAL TEMPERATURES &
PRESSURES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE TOXIC OXIDES OF CARBON & MAGNESIUM.
==================== Disposal Considerations ====================
Waste Disposal Methods:OBSERVE ALL FEDERAL, STATE & LOCAL REGULATIONS
WHEN DISPOSING OF THIS SUBSTANCE. FOR ASSISTANCE, CONTACT THE
DISTRICT DIRECTOR OF THE EPA.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FERROUS AMMONIUM SULFATE, CAT #5064
Resp. Party Other MSDS Num.:F1616
CAGE:70829
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:FERROUS AMMONIUM SULFATE
CAS:10045-89-3
RTECS #:WS5890000
Minumum % Wt:90.
Maxumum % Wt:100.
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RAT LD50: 3250 MG/KG
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: CAUSES IRRITATION TO THE
RESPIRATORY TRACT. SYMPTOMS MAY INCLUDE COUGHING, SHORTNESS OF
BREATH. INGESTION: CAUSES IRRITATION TO THE GASTROINTESTINAL TRACT.
SYMPTOMS INCLUDE VOMITING, NAUSE A AND DIARRHEA. LOW TOXICITY IN
SMALL QUANTITIES BUT LARGER DOSES MAY CAUSE NAUSEA, VOMITING ,
DIARRHEA AND BLACK STOOL. PINK URINE DISCOLORATION IS A STRONG
INDICATOR OF IRON POISONING. LIVER DAMAGE,COMA, DEATH FROM IRON
POISONING HAS BEEN RECORDED. SKIN: CAUSES IRRITATION. SYMPTOMS
INCLUDE REDNESS, ITCHING, AND PAIN. EYE: CAUSES IRRITATION, REDNESS
AND PAIN. CHRONIC: NO INFORMATION FOUND.
Effects of Overexposure:INHALATION: CAUSES IRRITATION TO THE
RESPIRATORY TRACT. SYMPTOMS MAY INCLUDE COUGHING, SHORTNESS OF
BREATH. INGESTION: CAUSES IRRITATION TO THE GASTROINTESTINAL TRACT.
SYMPTOMS INCLUDE VOMITING, NAUSE A AND DIARRHEA. LOW TOXICITY IN
SMALL QUANTITIES BUT LARGER DOSES MAY CAUSE NAUSEA, VOMITING ,
DIARRHEA AND BLACK STOOL. PINK URINE DISCOLORATION IS A STRONG
INDICATOR OF IRON POISONING. LIVER DAMAGE,COMA, DEATH FROM IRON
POISONING HAS BEEN RECORDED. SKIN: CAUSES IRRITATION. SYMPTOMS
INCLUDE REDNESS, ITCHING, AND PAIN. EYE: CAUSES IRRITATION, REDNESS
AND PAIN. CHRONIC: NO INFORMATION FOUND.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS OR EYE PROBLEMS, OR IMPAIRED LIVER, KIDNEY OR RESPIRATORY
FUNCTION MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THIS SUBSTANCE.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN. GET
MEDICAL ATTENTION. INGESTION: INDUCE VOMITING IMMEDIATELY AS
DIRECTED BY MED ICAL PERSONNEL. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. GET MEDICAL ATTENTION. SKIN: IMMEDIATELY FLUSH
SKIN WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. REMOVE
CONTAMINATED CLOTHING AN D SHOES. GET MEDICAL ATTENTION. WASH
CLOTHING BEFORE REUSE. THOROUGHLY CLEAN SHOES BEFORE REUSE. EYE:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES, LIFTING UPPER AND LOWER EYELI DS OCCASIONALLY. GET MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE ANY MEANS SUITABLE FOR EXTINGUISHING
SURROUNDING FIRE.
Fire Fighting Procedures:USE PROTECTIVE CLOTHING AND BREATHING
EQUIPMENT APPROPRIATE FOR THE SURROUNDING FIRE.
Unusual Fire/Explosion Hazard:NOT CONSIDERED TO BE AN EXPLOSION HAZARD.
IRRITATING AND TOXIC AMMONIA GAS MAY FORM IN FIRES.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA OF LEAK OR SPILL. WEAR
APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT. SWEEP UP AND
CONTAINERIZE FOR RECLAMATION OR DISPOSAL. VACUUMING OR WET SWEEPING
MAY BE USED TO AVOID DUST DISPERSAL. S MALL AMOUNTS OF RESIDUE MAY
BE FLUSHED TO SEWER WITH PLENTY OF WATER. THE TOLL FREE NUMBER FOR
THE US COAST GUARD NATIONAL RESPONSE CENTER IS (800) 424-8802.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN TIGHTLY CLOSED LIGHT-RESISTANT
CONTAINER, STORED IN A COOL, DRY, VENTILATED AREA. PROTECT AGAINST
PHYSICAL DAMAGE. CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTY SINCE THEY RETAIN PRO DUCT RESIDUES (DUST, SOLIDS); OBSERVE
ALL WARNINGS AND PRECAUTIONS LISTED FOR THIS PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:HALF-FACE DUST/MIST RESPIRATOR (UP TO 10 TIMES
EXPOSURE LIMIT), FULL-FACEPIECE DUST/MIST RESPIRATOR (UP TO 50
TIMES EXPOSURE LIMIT), FULL-FACEPIECE POSITIVE-PRESSURE,
AIR-SUPPLIED RESPIRATOR (FOR EMER GENCIES). DO NOT EXCEED THE
MAXIMUM USE CONCENTRATION SPECIFIED BY THE APPROPRIATE REGULATORY
AGENCY, OR RESPIRATOR SUPPLIER, WHICHEVER IS LOWER.
Ventilation:LOCAL &/OR GENERAL EXHAUST IS RECOMMENDED TO KEEP EMPLOYEE
EXPOSURES BELOW AIRBORNE EXPOSURE LIMITS. LOCAL VENTILATION IS
GENERALLY PREFERRED.
Other Protective Equipment:WEAR IMPERVIOUS PROTECTIVE CLOTHING,
EYE WASH FOUNTAIN AND QUICK-DRENCH FACILITIES IN WORK AREA.
Supplemental Safety and Health
PRODUCT CODES: J.T. BAKER: 2054; MALLINCKRODT: 5064.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:100-110C
Vapor Pres:NO INFO
Vapor Density:>1.0
Spec Gravity:1.86
pH:NO INFO
Evaporation Rate & Reference:NO INFO
Solubility in Water:26.9G/100CC H20 @ 20C
Appearance and Odor:PALE BLUE-GREEN CRYSTALS. ODORLESS.
Percent Volatiles by Volume:0%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SULFURIC ACID
Stability Condition to Avoid:HEAT, LIGHT, MOISTURE
Hazardous Decomposition Products:MAY EMIT AMMONIA, OXIDES OF SULFUR,
OXIDES OF NITROGEN, AND OXIDES OF CARBON.
=================== Toxicological Information===================
Toxicological Information:ORAL RAT LD50: 3250 MG/KG.
===================== Ecological Information =====================
Ecological:NO INFORMATION FOUND.
==================== Disposal Considerations ====================
Waste Disposal Methods:USE AN APPROPRIATE AND APPROVED WASTE DISPOSAL
FACILITY. PROCESSING, USE OR CONTAMINATION OF THIS PRODUCT MAY
CHANGE THE WASTE MANAGEMENT OPTIONS. STATE AND LOCAL DISPOSAL
REGULATIONS MAY DIFFER FROM FEDERAL DISPOSAL REGULATIONS. DISPOSE
OF CONTAINER AND UNUSED CONTENTS IN ACCORDANCE WITH FEDERAL, S TATE
& LOCAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:NOT REGULATED.
===================== Regulatory Information =====================
SARA Title III Information:SARA 311/312- ACUTE: YES. CHRONIC: NO. FIRE:
NO. PRESSURE: NO.
Federal Regulatory Information:TSCA LISTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HALON 1302, FREON FE 1301
CAGE:03670
CAGE:03670
============= Composition/Information on Ingredients =============
Ingred Name:TRIFLUOROBROMOMETHANE (HALON 1301) (SARA 313) (CERCLA)
CAS:75-63-8
RTECS #:PA5425000
Fraction by Wt: >99%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9596
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
LD50 LC50 Mixture:LC50=416 GM/CUM (RAT)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES- THE LIQUID FORM OF THIS MATERIAL
CAN PRODUCE CHILLING SENSATIONS AND DISCOMFORT. SKIN- EVAPORATION
OF LIQUID FROM THE SKIN CAN PRODUCE CHILLING SENSATIONS. FROSTBITE
CAN OCCUR. INHALATION- VAPOR IS HEAVIER THAN AIR AND CAN CAUSE
SUFFOCATION BY REDUCING OXYGEN AVAILABLE FOR BREATHING. MAY LEAD TO
NARCOSIS, DEATH.
Effects of Overexposure:ACUTE: DIZZINESS, IMPAIRED COORDINATION,
REDUCED MENTAL ACUITY, AND CARDIAC EFFECTS CAN OCCUR.
UNCONSCIOUSNESS OR EVEN DEATH IN HIGH CONCENTRATIONS WITH LONGER
EXPOSURES. CHRONIC: NONE KNOWN WHEN OCCU PATIONAL EXPOSURE ARE
BELOW THE TLV.
Medical Cond Aggravated by Exposure:CARDIAC PROBLEMS. ALSO, PRODUCT IS
AN ASPHYXIANT & CAN INDUCE CARDIAC MUSCLE SENSITIZATION TO
CIRCULATING EPINEPHRINE-LIKE COMPOUNDS.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH WITH PLENTY OF WATER FOR 15MIN WHILE HOLDING LIDS
OPEN. SKIN: WASH WITH COPIOUS AMOUNTS OF SOAP & WATER FOR AT LEAST
15MIN, IF REDNESS, ITCHING OCCURS, GET MEDICAL ATTN, TREAT
FROSTBITE IF NECESSARY. INHALATION: REMOVE TO FRESH AIR, IF COUGH
OR OTHER RESPIRATORY SYMPTOMS OCCUR, CONSULT MEDICAL PERSONNEL.
INGESTION: NOT LIKELY TO OCCUR.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:THIS IS A FIRE EXTINGUISHING AGENT.
Fire Fighting Procedures:USE WATER TO COOL FIRE-EXPOSED CYLINDERS OR
OTHER CONTAINERS. SELF-CONTAINED BREATHING APPARATUS WITH FULL
FACEPIECE AND PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:CONTAINERS ARE EQUIPPED WITH PRESSURE AND
TEMPERATURE RELIEF DEVICES, BUT RUPTURE MAY OCCUR UNDER FIRE
CONDITIONS AND TOXIC DECOMPOSITION BY-PRODUCTS CAN FORM.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA, VENTILATE TO OUTSIDE
ATMOSPHERE. COOL OR REMOVE HOT, METAL SURFACES OR SOURCE OF
NON-EXTINGUISHED FLAMES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AS A LIQUEFIED COMPRESSED GAS IN
DOT APPROVED PRESSURE VESSELS AWAY FROM HIGH TEMPERATURE.
Other Precautions:IF CYLINDER IS NOT CONNECTED TO A SYSTEM,IT MUST BE
SAFETY CAPPED TO PROTECT AGAINST ACTUATION OF VALVE & RELEASE OF
AGENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY NECESSARY IF CONTROLS ARE ADEQUATE.
FOR HIGH CONCENTRATIONS EXCEEDING 10%,OR IF EXPOSURE IS
PROLONGED,USE POSITIVE PRESSURE AIR-SUPPLIED RESPIRATOR.
Ventilation:MECHANICAL & LOCAL EXHAUST.
Other Protective Equipment:SAFETY SHOWER & EYE WASH ARE GOOD SAFETY
PRACTICE IN WORK AREAS WHEN WORKING WITH LIQUEFIED PRODUCT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:G3
Boiling Pt:B.P. Text:-72F,-58C
Melt/Freeze Pt:M.P/F.P Text:-270F,-168C
Vapor Pres:199 PSI
Vapor Density:5.2
Spec Gravity:1.57
Solubility in Water:NEGLIGIBLE
Appearance and Odor:SWEET ODOR, COLORLESS GAS.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACTIVE METALS, FIRES OF METAL HYDRIDES, STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXTREMELY HIGH TEMPERATURES
Hazardous Decomposition Products:CO, CO2,OXIDES OF BROMIDE & FLORIDE,
HYDROGEN BROMIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN COMPLIANCE WITL LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MILD STEEL COVERED ELECTRODES,E 5010
CAGE:84021
CAGE:84021
============= Composition/Information on Ingredients =============
Ingred Name:IRON
CAS:7439-86-6
RTECS #:NO6925000
Other REC Limits:NONE SPECIFIED
OSHA PEL:10 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:CHROMIUM (SARA III)
CAS:7440-47-3
RTECS #:GB4200000
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:ZIRCONIUM SILICATE
Other REC Limits:NONE SPECIFIED
OSHA PEL:NOT ESTABLISHED.
ACGIH TLV:NOT ESTABLISHED.
Ingred Name:SODIUM METASILICATE
CAS:6834-92-0
RTECS #:VV9275000
Other REC Limits:NONE SPECIFIED
Ingred Name:CALCIUM CARBONATE (MARBLE) (LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9192
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Other REC Limits:NONE SPECIFIED
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9293
Ingred Name:POTASSIUM SILICATE
CAS:1312-76-1
Other REC Limits:NONE SPECIFIED
Ingred Name:CALCIUM FLUORIDE
CAS:7789-75-5
RTECS #:EW1760000
Other REC Limits:NONE SPECIFIED
OSHA PEL:2.5 MG/M3 AS F (MFR)
ACGIH TLV:2.5 MG/M3 AS F (MFR)
Ingred Name:POTASSIUM ALUMINUM SILICATE (FELDSPAR)
CAS:68476-25-5
Other REC Limits:NONE SPECIFIED
Ingred Name:ZIRCONIUM DIOXIDE/ZIRCONIUM SILICATE
CAS:7440-67-7
RTECS #:ZH7070000
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:POTASSIUM TITANATE
CAS:12030-97-6
Other REC Limits:NONE SPECIFIED
Ingred Name:MAGNESITE/MAGNESIUM CARBONATE
CAS:546-93-0
RTECS #:OM2470000
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9192
Ingred Name:ALPHA-ALUMINA (ALUMINUM OXIDE) (EPA LISTS ONLY FIBROUS
FORMS) (SARA III)
CAS:1344-28-1
RTECS #:BD1200000
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:MAGNESIUM OXIDE
CAS:1309-48-4
RTECS #:OM3850000
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 PARTICULATE
ACGIH TLV:10 MG/M3;TDUST; 9293
Ingred Name:CELLULOSE (PAPER FIBER)
CAS:9004-34-6
RTECS #:FJ5691460
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9192
Ingred Name:BENTONITE(INORGANIC CLAY)
CAS:1302-78-9
RTECS #:CT9450000
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 (DUST)
ACGIH TLV:5 MG/M3 (DUST)
Ingred Name:MICA - SILICATES (< 1% CRYSTALLINE SILICA)
CAS:12001-26-2
RTECS #:VV8760000
Other REC Limits:NONE SPECIFIED
OSHA PEL:20 MPPCF
ACGIH TLV:3 MG/M3 RDUST; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE-EYES/SKIN:ARC RAYS CAN INJURE
EYES & BURNS SKIN.INHALATION:WELDING FUMES MAY RESULT IN
DISCOMFORT(DIZZINESS,NAUSEA,DRYNESS/IRRITATION)OF NOSE,THROAT OR
EYES.ELECTRIC SHOCK CAN KILL.CHRONIC-INHAL ATION:IRON MAY DEPOSIT
IN LUNG & AFFECTS PULMONARY FUNCTION.
Explanation of Carcinogenicity:NTP & IARC LIST NICKEL AND ITS COMPOUNDS
AS POSING CARCINOGEN TO HUMAN.CONTAINS CR & NI (PER MSDS).
Effects of Overexposure:ARC RAYS CAN INJURE EYES & BURNS SKIN. WELDING
FUMES MAY RESULT IN DISCOMFORT (DIZZINESS, NAUSEA,
DRYNESS/IRRITATION) OF NOSE, THROAT OR EYES. ELECTRIC SHOCK CAN
KILL.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES OR RESPIRATORY
TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:CALL FOR MEDICAL AID.EMPLOY FIRST AID TECHNIQUES RECOMMENDED
BY THE AMERICAN RED CROSS.INHALED:REMOVE TO FRESH AIR.PROVIDE
CPR/OXYGEN IF NEEDED.IN CASE OF ELECTRICAL SHOCK,TURN OFF POWER &
FOLLOW RECO MMENDED TREATMENT.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:WELDING ARC AND SPARKS CAN IGNITE
COMBUSTIBLE MATERIALS.
================== Accidental Release Measures ==================
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A DRY PLACE.
Other Precautions:READ AND UNDERSTAND THE MANUFACTURER'S INSTRUCTIONS
AND THE PRECAUTIONARY LABEL ON THE PRODUCT. AVOID BREATHING FUMES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL(TLV), USE RESPIRABLE FUME RESPIRATOR OR AIR
SUPPLIED RESPIRATOR WHILE WELDING IN CONFINED SPACE OR GENERAL WORK
AREA.
Ventilation:LOCAL EXHAUST AT THE ARC.
Other Protective Equipment:WEAR HAND, HEAD AND BODY PROTECTION WHICH
HELP TO PREVENT INJURY FROM RADIATION, SPARKS AND ELECTRICAL SHOCK.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
INSULATE FROM WORK AND GROUND. TRAIN THE WELDER NOT TO PERMIT
THEY ARE WET.
================== Physical/Chemical Properties ==================
HCC:N1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES
Hazardous Decomposition Products:CO,CO2,FLUORIDES,OZONE,NITROGEN
OXIDE,COMPLEX OXIDES CONTAINING
IRON,CHROMIUM,MANGANESE,NICKEL,SILICON,MOLYBDENUM
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT.DISCARD ANY PRODUCT, RESIDUE, DISPOSABLE CONTAINER OR
LINER IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL
LAWS AND REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ENDURANCE SEMI-TRANSPARENT DECK STAIN/CLEAR
CAGE:72818
CAGE:72818
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL SPIRITS (DISTILLATES (PETROLEUM), HYDROTREATED
LIGHT) LD50: (ORAL,RAT) 800 MG/KG
CAS:64742-86-5
RTECS #:LX3296500
Fraction by Wt: 70-80%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:CRYSTALLINE SILICA, QUARTZ; (QUARTZ)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 1-5%
Other REC Limits:PEL 0.1 MG/M3 (MFR)
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:ALKYD RESIN; (TALL OIL FATTY ACID, PENTAERYTHRITOL,
GLYCERIN PHTHALIC ANHYDRIDE RESIN)
CAS:66070-52-0
Fraction by Wt: 10-20%
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL: IRRIT OF RESP TRACT, PRLNG
INHAL MAY LEAD TO FATIGUE, DROWSINESS, DIZZ &/OR LIGHTHEADEDNESS,
HDCH, UNCOORDINATION, NAUSEA, CNS DEPRESSION, UNCON, ASPHYXIATION,
DEATH. SKIN: IRRIT OF SKIN, PRLNG /RPTD CNTCT CAN CAUSE DERMATITIS,
DEFATTING, BLURRED VISION. EYE: IRRIT OF EYES, PRLNG/RPTD CNTCT CAN
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:CRYSTALLINE SILICA: CLASS 2A (IARC)
Effects of Overexposure:HLTH HAZ: CAUSE BLURRED VISION/TEARING OF
EYES/REDNESS OF EYES/SEVERE EYE IRRIT. INGEST: MAY CAUSE
FATIGUE/DROWS/ DIZZ/ &/OR
LIGHTHEADEDNESS/UNCOORDINATION/NAUSEA/VOMIT/DIARR/DIGESTIVE SYS
PROBLEMS, C NS DEPRESS. RPTD/PRLNG OVEREXP HAS BEENASSOC
W/PERMANENT BRAIN & CNS DAMAGE INTENTIONAL MISUSE BY INHALING (SUPP
DATA)
Medical Cond Aggravated by Exposure:EYE, SKIN, RESPIRATORY DISORDERS
LUNG DISORDERS ASTHAM-LIKE CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
GET EMERGENCY MED ATTN. HAVED TRAINED PERSON GIVE O2 IF NEC. GET
MED HELP FOR ANY BRTHG DFCLT. SKIN:WASH OFF QUICKLY W/PLENTY OF
H2O, THEN SOAP & H2O. REMOVE CONTAM CLTHG. WASH CONTAM CLTHG
BEFORE RE- USE. EYE:FLUSH IMMED W/LRG AMTS OF H2O, ESPECIALLY UNDER
LIDS FOR AT LEAST 15 MIN. GET EMERGENCY TRTMT. INGEST: GET MED
TRTMT IMMED.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:105F,41C
Lower Limits:0.7 %
Extinguishing Media:DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:WATER MAY BE USED TO COOL AND PROTECT EXPOSED
CONTAINERS. WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CLSD CNTNRS MAY EXPLO WHEN EXPOS TO
EXTREME HEAT/FIRE. VAPS CAN FORM EXPLO MIX IN AIR AT ELEVATED
TEMPS. MAY DECOMPOSE UNDER FIRE CNDTNS EMITTING (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:COMPLY W/ALL APPLICABLE HLTH & ENVIRON REGS.
ELIMINATE ALL SOURCES OF IGNIT. VENT AREA. SPILLS MAY BE COLLECTED
W/ABSORB MATLS. LRG SPILLS: SHUT OFF LEAK IF SAFE TO DO SO. PUMP TO
STOR/SALVAGE VESSELS . USE ABSORB TO PICK UP EXCESS RESIDUE.(SUPP
DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 100 F. KEEP AWAY FROM
HEAT, SPARKS AND OPEN FLAMES. USE ONLY WITH ADEQUATE VENTILATION.
DO NOT TAKE INTERNALLY.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID CNTCT W/SKIN &
EYES, & BRTHG OF VAPS. WASH HANDS THORO AFTER HNDLG. ESPECIALLY
BEFORE EATING/SMOKING. KEEP CNTNRS TIGHTLY CLSED & UPRIGHT WHEN NOT
IN USE. EMPTY CO NTAINERS MAY CONTAIN HAZ RESIDUES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW
APPLICABLE STANDARDS. WHERE RESPIRATORY PROTECTION IS REQUIRED, USE
ONLY NIOSH/MSHA APPROVED RESPIRATORS IN ACCORDANCE WITH OSHA
STANDARD 29 CFR 1910.134.
Ventilation:PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT
BUILD-UP OF VAPORS.
Other Protective Equipment:EYE WASH AND SAFETY SHOWER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ: IRRITANT AND/OR TOXIC GASES. EFTS OF OVEREXP: HIGH
CONCENTRATIONS MAY BE FATAL. INGESTION OF LARGE AMOUNTS MAY CAUSE
LUNG INFLAMMATION AND DAMAGE. SPILL PROC: KEEP SALVAGE MATL & RINSE
WATE R OUT OF SEWERS OR WATER COURSES.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:310F,154C
Spec Gravity:0.849
Appearance and Odor:CLEAR LIQUID.
Percent Volatiles by Volume:79.23
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDZERS, ACIDS, BASES, AMINES.
Stability Condition to Avoid:ELEVATED TEMPERATURES. CONTACT WITH
OXIDIZING AGENTS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL REGULATIONS. AVOID DISCHARGE TO NATURAL
WATERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AVAROX DBPH
CAGE:IN612
CAGE:IN612
CAGE:1N612
============= Composition/Information on Ingredients =============
Ingred Name:2,5-DIMETHYL-2,5-DI(T-BUTYLPEROXY)HEXANE, MFR GIVES ACUTE
ORAL LD50>32GM/KG, RAT.
CAS:786-37-4
RTECS #:MO1835000
Fraction by Wt: 90%
===================== Hazards Identification =====================
Effects of Overexposure:IRRIT TO SKIN/EYES. MFR GIVES ACUTE DERMAL LD50
4.1GM/KG, RABBITS.
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & WATER. EYES: IMMED FLUSH W/WATER AT LEAST
15 MIN, CALL MD. INGEST: ADMINISTER EMETIC TO INDUCE VOMIT, CALL
MD.
===================== Fire Fighting Measures =====================
Flash Point:162F, 72C OC
Extinguishing Media:SM FIRE: DRY CHEM, FOAM, CO*2. LG: APPLY SPRAY OF
WATER.
Fire Fighting Procedures:COOL CNTNRS W/WATER
Unusual Fire/Explosion Hazard:EVACUATE AREA DURING FIRE
================== Accidental Release Measures ==================
Spill Release Procedures:MFR SUGGESTS BLEND W/CLAY, SWEEP INTO
NONSPARKING SHOVEL, DEPOSIT OVER SM PILE OF KINDLING IN SHALLOW
TRENCH & IGNITE W/LONG TORCH (KEROSENE-SOAKED RAG ON 6FT STEEL
ROD).
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT 65-85F TO PREVENT LOSS OF
ACTIVE OXYGEN. DO NOT TRANSFER FROM ORIGINAL CNTNRS INTO CLOSED
GLASS CNTNRS.
Other Precautions:DO NOT ADD ACCELERATORS USED IN POLYMERIZATION
REACTIONS OR DIMETHYLANILINE, COMMON ORGANIC BASE, DIRECTLY TO
VAROX. KEEP AWAY FROM SOURCES OF HEAT & SOURCES OF IGNITION.
============= Exposure Controls/Personal Protection =============
Ventilation:LOCAL EXHST PREFERRED. MECH, YES.
Supplemental Safety and Health
INGRED % IS MINIMUM
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:480F
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS TO LIGHT YELLOW
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONTAM W/STRNG OXIDZRS/REDUCRS,POLYMRZTN ACCEL,COMBUSTIBLES
Stability Condition to Avoid:>180F, 82C, MAY CAUSE RELEASE OF FLAM
VAPORS/MAY SELF-IGNITE
Hazardous Decomposition Products:CH*4, C*2H*6, C*2H*4, ACETONE,
T-BUTANOL
==================== Disposal Considerations ====================
Waste Disposal Methods:DRAIN THOROUGHLY & FLUSH EMPTY CNTNRS BEFORE
DISCARDING. DISPOSE IAW LOCAL, STATE, FED REG.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:GREY CELOGLISS BF45426/7203
CAGE:F1419
CAGE:F1419
============= Composition/Information on Ingredients =============
Ingred Name:AROMATIC HYDROCARBONS
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:2-ETHOXYETHYL ACETATE (CELLOSOLVE ACETATE) (EGEEA)
CAS:111-15-9
RTECS #:KK8225000
Fraction by Wt: 12%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S,100 PPM
ACGIH TLV:S, 5 PPM; 9293
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 12%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:POLYTETRAFLUOROETHYLENE
CAS:116-14-3
RTECS #:KX4025000
Fraction by Wt: 18%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYESTER RESIN
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:PIGMENTS
Fraction by Wt: 24%
Other REC Limits:NONE RECOMMENDED
Ingred Name:KETONE
Fraction by Wt: 4%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYOL
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NO INFORMATION GIVEN ON MSDS BY MFR.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:UNKNOWN IARC:UNKNOWN OSHA:NO
Health Hazards Acute and Chronic:PRODUCT IS TOXIC IF INGESTED, HARMFUL
IF BREATHED AND IRRITATING TO EYES. ACUTE EXPOSURE MAY CAUSE
CENTRAL NERVOUS SYSTEM DEPRESSION AND MINOR REVERSABLE EFFECTS UPON
LIVER & KIDNEYS.
Explanation of Carcinogenicity:THE INGREDIENT DESCRIBED ONLY AS
"AROMATIC HYDROCARBON" MAY OR MAY NOT CONTAIN BENZENE, A
CARCINOGEN.
Effects of Overexposure:EUE:IRRITATION. SKIN:NO INFORMATION GIVEN ON
MSDS BY MFR. INHALED:CENTRAL NERVOUS SYSTEM EFFECTS (HMIS:CNS
DEPRESSION, SIGNS OF INTOXICATION.) INGESTED:TOXIC TO LIVER,
KIDNEYS.
Medical Cond Aggravated by Exposure:NO INFORMATION GIVEN ON MSDS BY
MFR.
======================= First Aid Measures =======================
First Aid:EYE:RINSE WITH PLEANTEY OF WATER AND GET MEDIOCAL ATTENTION.
SKIN:NO INFORMATION GIVEN ON MSDS BY MFR. (HMIS:WASH W/SOAP &
WATER.) INHALED:REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT,
GET MEDICAL ATTENTION. INGESTED:GET MEDICAL ATTENTION. (HMIS:DO
NOT INDUCE VOMITING.)
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:73.4F,23.0C
Autoignition Temp:Autoignition Temp Text:330
Lower Limits:1
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:MFR: ? HMIS:FIRE FIGHTERS SHOULD USE NIOSH
APPROVED SCBA & FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL
FIRE.
Unusual Fire/Explosion Hazard:NO INFORMATION GIVEN ON MSDS BY MFR.
================== Accidental Release Measures ==================
Spill Release Procedures:NO INFORMATION GIVEN ON MSDS BY MFR.
Neutralizing Agent:NO INFORMATION GIVEN ON MSDS BY MFR.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER IN A WELL VENTILATED
PLACE.
Other Precautions:SHELF LIFE IN NORMAL STORAGE IS 2 YEARS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO INFORMATION GIVEN ON MSDS BY MFR.
Ventilation:MFR: ? HMIS:PROVIDE GENERAL AND LOCAL EXHAUST SUFFICIENT TO
MAINTAIN EXPOSURES TO LESS THAN TLV/PEL.
Other Protective Equipment:NO INFORMATION GIVEN ON MSDS BY MFR.
Work Hygienic Practices:MFR: ?HMIS:USE GOOD CHEMICAL HYGIENE
PRACTICE. AVOID UNNECESSARY CONTACT. WASH THOROUGHLY BEFORE EATING
OR DRINKING.
Supplemental Safety and Health
KEY2:KT
================== Physical/Chemical Properties ==================
HCC:F3
NRC/State Lic Num:NONE
Vapor Pres:100 MM
Spec Gravity:1.290
Appearance and Odor:GREY LIQUID, ODOR NOT GIVEN
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MATERIAL DOES *NOT* REACT VIOLENTLY WITH WATER, AIR OR ANYTHING ELSE
LISTED ON THE MSDS.
Stability Condition to Avoid:NO INFORMATION GIVEN ON MSDS BY MFR.
Hazardous Decomposition Products:NO INFORMATION GIVEN ON MSDS BY MFR.
Conditions to Avoid Polymerization:APPARENTLY WILL NOT OCCUR
==================== Disposal Considerations ====================
Waste Disposal Methods:FOR BOTH UNUSED & SPENT MATERIAL: DISCARD I/A/W
FEDERAL, STATE & LOCAL REGULATIONS. DO NOT EMPTY WASTE WATER INTO
DRAINS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:155 8600 MICROFILM MINI PROCESSING DEVELOPER
Kit Part:Y
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 70 - 75%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
Ingred Name:POTASSIUM SULFITE
CAS:10117-38-1
RTECS #:WT3530000
Fraction by Wt: 10 - 15%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIETHYLENE GLYCOL
CAS:111-46-6
RTECS #:ID5950000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:HYDROQUINONE (SARA 302/313) (CERCLA)
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: 4%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9596
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:POTASSIUM HYDROXIDE (CERCLA)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:POTASSIUM CARBONATE
CAS:584-08-7
RTECS #:TS7750000
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, TEARING, NAUSEA, VOMITING
Medical Cond Aggravated by Exposure:SOME ASTHMATICS OR
SULFITE-SENSITIVE INDIVIDUALS MAY EXPERIENCE WHEEZING, CHEST
TIGHTNESS, STOMACH UPSET, HIVES, FAINTNESS, WEAKNESS AND DIARRHEA.
======================= First Aid Measures =======================
First Aid:CALL PHYSICIAN IF SYMPTOMS DEVELOP. EYE:IMMEDIATELY FLUSH
WITH WATER FOR 15 MINUTES. HOLD EYELIDS OPEN. CALL PHYSICIAN.
SKIN:FLUSH WITH PLENTY OF WATER. INHALED:MOVE TO FRESH AIR. PROVIDE
CPR/OXYGEN I F NEEDED. ORAL:ONLY INDUCE VOMITING AT INSTRUCTION OF
PHYSICIAN. CALL A PHYSICIAN/POISON CONTROL CENTER IMMEDIATELY.
NEVER GIVE FLUID OR INDUCE VOMITING IF PATIENT IS UNCONSCIOUS OR
HAS CONVULSIONS.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NOT RELEVANT
Upper Limits:NOT RELEVANT
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. HAZARDOUS DECOMPOSITION
PRODUCTS MAY BE FORMED.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNT OF WATER IF
PERMITTED. OTHERWISE, ABSORB SPILL WITH INERT MATERIAL SUCH AS
VERMICULITE. PLACE IN A CONTAINER FOR DISPOSAL. CLEAN AREA
THOROUGHLY TO REMOVE RESIDUAL CON TAMINATION.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM STRONG ACIDS. KEEP
CONTAINER CLOSED. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:DO NOT GET IN EYES, ON SKIN/ON CLOTHING. WASH
THOROUGHLY AFTER HANDLING. THE ROUTINE USE OF A NONALKALINE TYPE OF
POSSIBILITY OF SKIN REACTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED. A NIOSH-APPROVED ACID GAS
RESPIRATOR MUST BE WORN IF HAZARDOUS DECOMPOSITION PRODUCTS ARE
LIKELY TO BE RELEASED OR HAVE BEEN RELEASED.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES/HR)
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:EYE BATH, SAFETY SHOWER, WASHING FACILITIES
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
KEY1:C4. ECOLOGICAL INFORMATION: THIS MATERIAL IS EXPECTED TO HAVE
FOLLOWING PROPERTIES: A MODERATE BIOCHEMICAL OXYGEN DEMAND, A HIGH
POTENTIAL TO AFFECT SOME AQUATIC ORGANISMS. AFTER DILUTION WITH LA
RGE AMOUNT OF WATER, FOLLOWED BY SECONDARY WASTE TREATMENT, IT IS
NOT EXPECTED TO CAUSE ADVERSE ENVIRONMENTAL EFFECTS.
================== Physical/Chemical Properties ==================
HCC:B3
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:18 @ 68F
Spec Gravity:1.18
pH:11.0
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT YELLOW LIQUID - ODORLESS
Percent Volatiles by Volume:72
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:SULFUR DIOXIDE, CARBON MONOXIDE,
CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE OR LOCAL LAWS. FLUSH TO SEWER WITH LARGE AMOUNT
OF WATER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:R2020 RNASEZAP
CAGE:21076
CAGE:21076
============= Composition/Information on Ingredients =============
Ingred Name:TRADE SECRET
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:MAY BE HARMFUL BY INHALATION,
INGESTION/SKIN ABSORPTION. CAUSES SEVERE IRRITATION. EXTREMELY
DESTRUCTIVE TO TISSUES OF MUCOUS MEMBRANES & UPPER RESPIRATORY
TRACT, EYES & SKIN. MAY CAUSE BURNING SENSAT ION.
Effects of Overexposure:IRRITATION, BURNING SENSATION, COUGHING,
WHEEZING, LARYNGITIS, SHORTNESS OF BREATH, HEADACHE, NAUSEA &
VOMITING.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH EYES/SKIN W/COPIOUS AMOUNTS OF WATER
FOR 15 MINS. INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF
NECESSARY. INGESTION: WASH OUT MOUTH W/WATER IF CONSCIOUS. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, DRY CHEMICAL POWDER/APPROPRIATE FOAM
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING TO PREVENT CONTACT W/SKIN & EYES.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA, WEAR SELF CONTAINED BREATHING
SAND/VERMICULITE & PLACE IN CLOSED CONTAINERS FOR DISPOSAL.
VENTILATE AREA & WASH SITE AFTER MATER IAL PICKUP IS COMPLETE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP
TIGHTLY CLOSED.
Other Precautions:DON'T BREATHE VAPOR. DON'T GET IN EYES, ON SKIN/ON
CLOTHING. AVOID PROLONGED/REPEATED EXPOSURE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:SAFETY SHOWER & EYE BATH, OTHER PROTECTIVE
CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
METALS, ACIDS
Stability Condition to Avoid:FIRE CONDITIONS, HEAT
Hazardous Decomposition Products:SODIUM/SODIUM OXIDES
=================== Toxicological Information===================
Toxicological Information:TO THE BEST OF OUR KNOWLEDGE, THE CHEMICAL,
PHYSICAL & TOXICOLOGICAL PROPERTIES HAVE NOT BEEN THOROUGHLY
INVESTIGATED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE/MIX THE MATERIAL W/A COMBUSTIBLE
SOLVENT & BURN IN A CHEMICAL INCINERATOR EQUIPPED W/AN AFTERBURNER
& SCRUBBER. DISPOSE OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL
REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:CONTACT SIGMA CHEMICAL COMPANY FOR TRANSPORTATION
INFORMATION.
===================== Regulatory Information =====================
State Regulatory Information:EUROPEAN INFORMATION: CAUTION: SUBSTANCE
NOT YET FULLY TESTED. IRRITANT S26 IN CASE OF CONTACT W/EYES, RINSE
IMMEDIATELY W/PLENTY OF WATER & SEEK MEDICAL ADVICE. S27 TAKE OFF
IMMEDIATELY ALL CONTAMINA TED CLOTHING. S36/37/39 WEAR SUITABLE
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SPOTCHECK DEVELOPER SKD-S2, 5 GAL
CAGE:59042
CAGE:37676
CAGE:59042
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPYL ALCOHOL; (2-PROPANOL) (SARA 313).
LD50:(ORAL,MOUSE) 3.6 G/KG.
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 40-70%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM;500 STEL
Ingred Name:ACETONE; (2-PROPANONE) (SARA 313) (CERCLA).
LD50:(ORAL,RAT) 6 G/KG.
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 10-30%
OSHA PEL:1000 PPM
ACGIH TLV:750 PPM;1000 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPANE, 2-METHYL-; (ISOBUTANE (PROPELLANT))
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 50%
OSHA PEL:1000 PPM (MFR)
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN CONTACT:CAN IRRITATE BY REMOVING
NATURAL SKIN OILS ON LONG OR REPEATED EXPOSURES. EYES:IRRITATING,
BUT DOES NOT DAMAGE EYE TISSUE. INHAL:CAUSES DIZZINESS & NAUSEA.
INGEST:NOT SIGNIFICANT IN SMALL (MOUTHFUL) AMOUNTS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:SKIN:WASH OFF W/SOAP & WATER. USE SOOTHING LOTION. EYES:RINSE
CAREFULLY UNDER UPPER & LOWER EYELIDS USING PLENTY OF WATER FOR AT
LST 15 MINS. INHAL:REMOVE TO FRESH AIR IF DIZZY/NAUSEATED.
INGEST:DO NO T INDUCE VOMIT. ACCIDENTAL INGEST OF SINGLE MOUTHFUL
IS NOT EXPECTED TO CAUSE SIGNIFICANT HARM. NOTE:IN ALL SEV CASES,
REGIONAL (SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:2F,-17C
Lower Limits:2%
Upper Limits:15%
Extinguishing Media:CARBON DIOXIDE, FOAM, WATER.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . KEEP CONTAINERS COOL W/WATER SPRAY.
Unusual Fire/Explosion Hazard:AEROSOL CANS MAY BURST OVER 130F (54C) &
ADD TO EXISTING FIRE. BULK & AEROSOL:IGNITION WILL OCCUR IS USED
NEAR FLAMES, ARCS OR OTHER IGNITION SOURCES.
================== Accidental Release Measures ==================
Spill Release Procedures:TURN OFF OR REMOVE SOURCES OF IGNITION. MOP UP
OR SWEEP UP W/ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING VAPORS. AVOID EYE
CONTACT. AVOID REPEATED OR PROLONGED SKIN CONTACT. STORE AWAY FROM
HEAT SOURCE. DO NOT SPRAY AROUND ARCS OR FLAME.
Other Precautions:EXTREMELY FLAMMABLE WHITE LIQUID & AEROSOL. FAST
EVAPORATING VAPORS CAN REACH HAZARDOUS LEVELS QUICKLY IN
UNVENTILATED SPACES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR W/FILTER IF
SPRAYED IN ENCLOSED, UNVENTILATED SPACE.
Ventilation:USE WHERE VENTILATION WILL CARRY VAPORS AWAY FROM
UNOCCUPIED AREAS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
VP:BULK:150 @ 100F. AEROSOL:65 PSI @ 75F. FIRST AID PROC:POISON CONTROL
CENTER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>132F,>56C
Vapor Pres:SUPP DATA
Vapor Density:3
Spec Gravity:0.87
pH:NEUT
Evaporation Rate & Reference:0.4 (ETHER)
Solubility in Water:90%
Appearance and Odor:WHITE LIQUID; ALCOHOL ODOR.
Percent Volatiles by Volume:90
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WHEN BURNING, SOOT, OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . SEND TO A LICENSED WASTE FACILITY FOR PROPER
DISPOSAL. RCRA:HAZARDOUS WASTE. U.S. EPA WASTE NUMBER:F003 & D001.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:829 ENAMEL
CAGE:EO706
CAGE:EO706
CAGE:07708
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE; DIMETHYL KETONE
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 33-42%
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL ACETATE
CAS:141-78-6
RTECS #:AH5425000
Fraction by Wt: 0-5%
Other REC Limits:400 PPM
OSHA PEL:1400 MG/CUM
ACGIH TLV:1400 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHANOL (ETHYL ALCOHOL), TECSOL, ALCOHOL
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 5-10%
Other REC Limits:1900 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ingred Name:DIACETONE ALCOHOL
CAS:123-42-2
RTECS #:SA9100000
Fraction by Wt: 5-10%
Other REC Limits:50 PPM
OSHA PEL:240 MG/CUM
ACGIH TLV:238 MG/CUM
Ingred Name:2-BUTANONE (METHYL ETHYL KETONE) (MEK)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 0-5%
Other REC Limits:590 MG/CUM
OSHA PEL:200 PPM
ACGIH TLV:590 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 5-10%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HYDROCARBON PROPELLANT, PETROLEUM GASES LIQUEFIED
SWEETENED, C3-7 *93-1*
CAS:68476-86-8
Fraction by Wt: 23%
Ingred Name:WEIGHT PER GALLON IN POUNDS: 7.8-8 (PAINT)
RTECS #:9999999WG
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NASAL & RESPIRATORY
IRRITATION, DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, HEADACHE,
POSSIBLE UNCONSCIOUSNESS & ASPHYXIATION. EYES: IRRITATION, REDNESS,
TEARING, & BLURRED VISION. INGESTION: GA STROINTESTINAL IRRITATION,
NAUSEA, VOMITING, & DIARRHEA. SKIN: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: PERMANENT BRAIN & NERVOUS SYSTEM
DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING & INHALING
THE CONTENTS MAY BE HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:RESPIRATORY &/OR SKIN REACTION
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT
ADMINISTER OXYGEN. IF BREATHING STOPS, GIVE ARTIFICIAL RESPIRATION.
EYES: FLUSH W/WATER FOR 15 MINS. INGESTION: DON'T INDUCE VOMITING.
ASPIRA TION OF MATERIAL INTO LUNGS CAN CAUSE PNEUMONITIS, WHICH CAN
BE FATAL. KEEP WARM & QUIET. SKIN: WASH W/SOAP & WATER OR VARIOUS
HAND CLEANERS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:0F/-18C
Lower Limits:1%
Extinguishing Media:ALCOHOL FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE, BUT MAY BE
USED TO COOL CLOSED CONTAINERS. FOG NOZZLES ARE PREFERABLE IF USING
WATER. WEAR SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE/AUTOIGNITE
DUE TO PRESSURE BUILD-UP & EXPOSURE TO EXTREME HEAT. VAPORS ARE
HEAVIER THAN AIR & MAY TRAVEL ALONG GROUND. FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. VENTILATE
AREA. ABSORB LIQUID ON PAPER, VERMICULITE, FLOOR ABSORBENT OR OTHER
ABSORBENT MATERIAL & TRANSFER TO CLOSED CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE ABOVE 120F OR IN DIRECT
SUNLIGHT. DON'T PUNCTURE OR INCINERATE.
Other Precautions:STORE LARGE QUANTITIES IN BUILDING PROTECTED FOR
STORAGE OF FLAMMABLE LIQUIDS. AVOID BREATHING VAPORS OR SPRAY MIST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA TC23C OR EQUIVALENT
Ventilation:SUFFICIENT MECHANICAL (GENERAL) &/OR LOCAL EXHAUST TO KEEP
EXPOSURE BELOW TLV. OPEN WINDOWS/DOORS TO ENSURE FRESH AIR.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS BEFORE EATING OR USING WASHROOM.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:133-331F
Melt/Freeze Pt:M.P/F.P Text: 1500F
Vapor Density:>1
Spec Gravity:<1
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT TO MODERATE
Appearance and Odor:TYPICAL SOLVENT PAINT
Percent Volatiles by Volume:85-90
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, PILOT LIGHTS, FLAMES, SPARKS,
HEATERS, SMOKING, ELECTRIC MOTORS, & OTHER IGNITION SOURCES
Hazardous Decomposition Products:CO2, CO, VARIOUS HYDROCARBONS,
NITROGEN COMPOUNDS
==================== Disposal Considerations ====================
Waste Disposal Methods:DEPOSIT ABSORBENT MATERIAL IN A POSTED TOXIC
SUBSTANCE LANDFILL IN ACCORDANCE W/FEDERAL, STATE, & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PAINT REMOVER, 8570
Preparer's Name:JOHN SCOTT
CAGE:78304
CAGE:78304
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIA
CAS:7664-41-7
Fraction by Wt: 5-8%
OSHA PEL:50 PPM
ACGIH TLV:25 PPM/35 STEL; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:METHYLENE CHLORIDE(SARA III)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 45-55%
OSHA PEL:500 PPM/C,1000; Z2
ACGIH TLV:50 PPM, A2; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 15-20%
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:SODIUM CHROMATE
CAS:7775-11-3
Fraction by Wt: 0.1-1%
OSHA PEL:25 UG
ACGIH TLV:50 UG/M3
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LISTED UNDER HEALTH HAZARDS
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ORAL-LD50 DICHLOROMETHANE - RAT 2136
MG/KG; SKIN-LD50 ISOPROPANOL - RABBIT 13,000 MK/KG; INHALATION
LC50(GASES,VAPORS) DICHLOROMETHANE - RAT 88,000 MG/M3/30
MININHALATION LC50(DUSTS,MISTS,FUMES) ISOPR OPANOL - RAT 16,000
PPM/8HR
Explanation of Carcinogenicity:METHLENE CHLORIDE & SODIUM CHROMATE ARE
HUMAN INDEFINITE AS A CARCINOGEN.
Effects of Overexposure:ACUTE:IRRITATION OF SKIN & EYES ON
CONTACT.INHALATION MAY CAUSE NAUSEA,DIZZINESS &
UNCONSCIOUSNESS.CHRONIC:POSSIBLE SKIN DAMAGE,LIVER, & CARDIO
VASCULAR DISEASECARCINOGENS.
======================= First Aid Measures =======================
First Aid:EYE & SKIN CONTACT FLUSH W/WTR FOR 15 MINS.OBTAIN MEDICAL
ATTN.INHALATION REMOVETO FRESH AIR.OBTAIN MEDICAL ATTN IF NEEDED
GIVE ARTIFICIAL RESPIRATION.INGESTIONDO NOT INDUCE VOMITING.OBTAIN
MEDICAL AT TN IMMEDIATELY.IF CONSCIOUS GIVE MILK,MILK OF MAGNESIA
OR EGG WHITES BEATEN W/WATER.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER FOG, CARBOND DIOXIDE CO2, FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/ABSORBENT MATERIAL & DRUM FOR
LANDFILL.
======================Handling and Storage ======================
Handling and Storage Precautions:WEAR APPROPRIATE PROTECTIVE GEAR WHEN
HANDLING MATERIAL.AVOID CONTACT.STORE IN COOL,DRY PLACE.KEEP
CONTAINERS CLOSED WHEN NOT IN USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:US NIOSH APPROVED SELF-CONTAINED BREATHING
APPARATUS.
Ventilation:LOCAL MAINTAIN BELOW TLV'S.
Other Protective Equipment:AVOID CONTACT W/EYES & SKIN & INHALATION OF
VAPORS.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:105F
Vapor Density:>1
Spec Gravity:1.05 - 1.06
pH:1
Solubility in Water:INSOLUBLE
Appearance and Odor:VISCOUS YELLOW LIQ W/AMMONIA ODOR
Percent Volatiles by Volume:75-85
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS
Stability Condition to Avoid:ACID MATERIALS
Hazardous Decomposition Products:THERMAL DECOMPOSITION CAN RESULT IN
EVOLUTION OF NITROGEN SULFUR & PHOSGENE.INCOMPLETE COMBUSTION
YIELDS CARBON MONOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:METHODS MATERIAL MUST BE DISPOSED OF IN APPROVED
CHEMICAL DUMP OR INCINERATOR.THIS MATERIAL IS CONSIDERED HAZARDOUS
& MUST BE DISPOSED OF IN ACCORDANCE W/LOCAL,STATE & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: SILCONE CURING AGENT, RTV668B
Cage: 01139
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 01139
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: TOLUENE APPEARS ON THE NAVY LISTING OF OCCUPATIONAL CHEM
REPRO HAZS. SEEK CONSULTATION FROM APPROPRIATE HEALTH PROFESSIONALS
CONCERNING LATEST HAZ LIST INFO & SAFE HANDLING & EXPOSURE
INFORMATION (FP N). INGEST:MAY BE HARMFUL IF SWALLOWED.SKIN:MAY CAUSE MILD
SKIN IRRIT. EYE:MAY CAUSE MILD EYE IRRIT. (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ:CHRONIC:THIS PROD CONTAINS
METHYLPOLYSILOXANES WHICH CAN GENERATE FORMALDEHYDE AT APPROXIMATELY 300F
(150C) & ABOVE, IN ATM WHICH CONTAIN OXYGEN. FORMALDEHYDE IS A SKIN &
RESP SENSITIZER, EYE& THROAT IRRIT, ACUTE TOXICANT & POTNTL CANCER
HAZ. AN MSDS FOR FORMALDEHYDE IS AVAIL FROM GE SILICONES.
Medical Cond Aggravated By Exposure: NONE KNOWN.
First Aid: INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP)
(FP N). INGEST: DO NOT INDUCE VOMITING. SLOWLY DILUTE WITH 1-2 GLASSES OF
WATER OR MILK AND SEEK MEDICAL ATTENTION. NEVER GIVE ANYTHI NG BY MOUTH TO AN
UNCONSCIOUS PERSON. SKIN:WASH WITH SOAP AND WATER. EYES:IN CASE OF CONTACT,
IMMED FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINUTES & GET MEDICAL
ATTENTION IF IRRITATION PERSISTS.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: WASH WALKING SURFACES WITH DETERGENT AND WATER TO
REDUCE SLIPPING HAZARD. WEAR PROPER PROTECTIVE EQUIPMENT AS SPECIFIED IN THE
PROTECTIVE EQUIPMENT SECTION. WIPE, SCRAPE, OR SOAK UP IN AN INERT MATL &
PUT IN A CNTNR INTENDED FOR FLAM MATLSFOR DISP.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS.
Handling And Storage Precautions: RECOMMENDED STORAGE IN ORIGINAL CNTNR BELOW
30C (85F). KEEP CONTAINER CLOSED WHEN NOT IN USE. AVOID CONTACT WITH SKIN
& EYES. DO NOT REUSE THIS CNTNR.
Other Precautions: RELIEVE ANY INTERNAL PRESS WHEN RECEIVED & AT LEAST
WEEKLY THEREAFTER BY SLOWLY LOOSENING BUNG. RETIGHTEN BUNG IMMED. CAUTION!
KEEP CNTNR CLSD WHEN NOT IN USE TO PVNT CNTCT W/ACIDIC, BASIC/OXIDIZING M
ATLS, & METALLIC CATALYSTS (SUPDAT)
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point Text: >250F,>121C
Extinguishing Media: ALL STANDARD FIREFIGHTING MEDIA.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF
CONCERN (FP N).
Ventilation: NONE KNOWN.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA. (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: USERS OF "L" VERSION OF SHOULD CONSULT "LR"
VERSION FOR ADDITIONAL INFORMATION (FP N). OTHER PREC: LIKE TIN SOAPS AND
NOBLE METALS (PH, RH, ETC.).
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
B.P. Text: >500F,>260C
Vapor Pres: NEG
Vapor Density: NEG
Spec Gravity: 1.03 (H*2O = 1)
Solubility in Water: INSOLUBLE
Appearance and Odor: SLIGHT GREEN LIQUID
Percent Volatiles by Volume: <1
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: PRODUCT GENERATES FLAMMABLE GAS ON CONTACT WITH
ACIDS, BASES OR OXIDIZING MATERIALS.
Materials To Avoid: AVOID CONTACT W/ACIDIC, BASIC, OR OXIDIZING AGENTS, &
METALLIC CATALYSTS LIKE TIN SOAPS AND NOBLE METALS (PT, RH, ETC)..
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE, SILICON
DIOXIDE, FORMALDEHYDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: SILCONE CURING AGENT, RTV668B
Cage: 01139
Company Name: GENERAL ELECTRIC CO, SILICONE PRODUCTS BUSINESS DEPT
Street: 260 HUDSON RIVER RD
Zipcode: 12188
Label Required IND: Y
Date Of Label Review: 11/13/1996
Status Code: C
Label Date: 11/13/1996
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE: INGESTION: MAY BE HARMFUL IF SWALLOWED. SKIN:
MAY CAUSE MILD SKIN IRRITAITON. EYE: MAY CAUSE MILD EYE IRRITATION. CHRONIC:
TOLUENE APPEARS ON THE NAVY OCCUPATIONAL CHEMICAL REPRODUCTIVE HAZARDS LIST
(FP N). THIS PRODUCT CONTAINS AN INGREDIENT WHICH CAN GENERATE FORMALDEHYDE
AT HIGH TEMPERATURES. FORMALDEHYDE IS A SKIN AND RESPIRATORY SENSITIZER, EYE
AND THROAT IRRITANT, ACUTE TOXICANT AND P OTENTIAL CANCER HAZARD.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HIBICLENS (SEE SUPP DATA)
CAGE:13992
)
CAGE:13992
============= Composition/Information on Ingredients =============
Ingred Name:CHLORHEXIDINE GLUCONATE
CAS:18472-51-0
RTECS #:DU1950000
Fraction by Wt: 4%
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 4%
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:NONIONIC SURFACTANTS
Ingred Name:FD&C DYE 40
Ingred Name:FRAGRANCE (PROPRIETARY BLEND)
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: TO 100%
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS 19-26 ML/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TOXICITY OF THIS PRODUCT IS VERY LOW.
IT IS HOWEVER, SLIGHTLY IRRITATING TO BODY TISSUES. NO CHRONIC
DATA IS GIVEN.
Explanation of Carcinogenicity:NONE OF THE CHEMICALS IN THIS PRODUCT IS
LISTED BY IARC, NTP OR OSHA AS A CARCINOGEN.
Effects of Overexposure:IRRITATION OF EYES, SKIN RESPIRATORY OR G/I
TRACT.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF SKIN AND
RESPIRATORY DISORDERS MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/ WATER 15 MIN HOLD LIDS OPEN. SKIN:WASH WITH
WATER. INHALED:REMOVE TO FRESH AIR. INGESTED:DO NOT INDUCE
VOMITING. GIVE 2 GLASSES OF WATER TO DRINK AND IF G/I SYMPTOMS
DEVELOP,GET IMMEDI ATE MEDICAL CARE. IF IRRITATION PERSISTS,OR IS
SEVERE,SEE A DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:148F,64C
Lower Limits:2
Upper Limits:12
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE.
Unusual Fire/Explosion Hazard:PRODUCT WILL QUICKLY SELF-EXTINGUISH.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE OR SOAK UP SMALL SPILLS WITH PAPER TOWEL
OR INERT ABSORBANT. PLACE IN DISPOSAL CONTAINER. FLUSH AREA WITH
WATER.
Neutralizing Agent:NONE APPLICABLE FOR THIS MATERIAL
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS CLOSED.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED. USE NIOSH/MSHA APPROVED
RESPIRATOR FOR ORGANIC VAPORS IF DESIRED OR NEEDED.
Ventilation:USE MECHANICAL OR LOCAL EXHAUST TO KEEP EXPOSURE TO A
MINIMUM.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH. OTHER EQUIPMENT
AS REQUIRED TO MINIMIZE EXPOSURE FROM PROLONGED OR REPEATED
CONTACT.
Work Hygienic Practices:USE GOOD HYGIENE PRACTICE. LAUNDER CONTAMINATED
CLOTHING BEFORE REUSE.
Supplemental Safety and Health
THIS MSDS COVERS THE GERMICIDAL SOAP INCLUDED WITH A DISPOSABLE
SURGICAL SCRUB BRUSH. CONTROL MEASURES COVER HANDLING INDUSTRIAL
QUANTITIES RATHER THAN THOSE TO TAKE UNDER NORMAL USE OF THE
PRODUCT. NORMAL USE SHOULD POSE VERY LITTLE HAZARD. CTDF:'THIS
ITEM DELETED,10AUG89.' NSN 6530-01-211-4810 IS A DUPLICATE.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.06
pH:5-6.5
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR RED LIQUID, PERFUME ODOR (SEE SUPP DATA)
Percent Volatiles by Volume:60-70
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
NITROGEN OXIDES, AMMONIA
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS. MFR CLAIMS PRODUCT
IS ORDINARY REFUSE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ACRYLIC ENAMEL REDUCER, DTR601
CAGE:DO894
CAGE:47695
CAGE:DO894
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 20%
Other REC Limits:PPG IPEL: 75
OSHA PEL:1000.00 PPM
ACGIH TLV:750.00 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-BUTOXY ETHYL ACETATE
CAS:112-07-2
RTECS #:KJ8925000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMME
Ingred Name:LIGHT ALIPHATIC SOLVENT NAPHTHA
CAS:8030-30-6
RTECS #:DE3030000
Fraction by Wt: 45%
Other REC Limits:NONE RECOMME
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 25%
Other REC Limits:PPG IPEL: 10
OSHA PEL:200.00 PPM
ACGIH TLV:100.00 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:INGEST: HARMFUL/FATAL. EYE:
IRRITATION. SKIN: MODERATE IRRITATION. MAY BE ABSORBD THROUGH SKIN.
INHAL: VAPOR & SPRAY MIST MAY BE HARMFUL. VAPOR IRRITATES EYES,
NOSE, & THROAT. REPEATED EXPOSURE (HIGH CONCENTRATION): RESP
IRRIT, PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE. CONCENTRATING &
INHALING MAY BE HARMFUL OR FATAL.
Effects of Overexposure:EYE WATERING, HEADACHE, NAUSEA, DIZZINESS, &
LOSS OF COORDINATION INDICATES THAT SOLVENT LEVELS ARE TOO HIGH.
REDNESS, ITCHING, BURNING SENSATION & VISUAL DISTURBANCES MAY
INDICATE EXCESSIVE EYE CONTA CT. DRYNESS, ITCHING, CRACKING,
BURNING, REDNESS, & SWELLING ARE CONDITIONS ASSOCIATED WITH
EXCESSIVE SKIN CONTACT.
======================= First Aid Measures =======================
First Aid:INGEST: DON'T INDUCE VOMITING. EYE: FLUSH EYES IMMED W/WATER
15 MIN. SKIN: FLUSH IMMED W/PLENTY OF WATER THEN WASHING W/SOAP &
WATER. INHAL: REMOVE TO FRESH AIR. APPLY ARTIF RESPIRATION & OTHER
SUPPOR TIVE MEASURES AS REQ'D. OTHER: IF ANY OF FOLLOWING OCCURS,
CONTACT POISON CONTROL CENTER, EMERG ROOM OR DR IMMED. HAVE MSDS
AVAILABLE. INGEST, EXPOSURE, PERSIST SKIN/EYE IRRIT/BREATHING
DIFFICULTIES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:12F,-11C
Lower Limits:1.5
Extinguishing Media:NFPA CLASS B EXTINGUISHER (CO2, DRY CHEMICAL, OR
UNIVERSAL AQUEOUS FILM FORMING FOAM) FOR NFPA CLASS 1B FLAMM LIQ
FIRE
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE, USE TO COOL
(FOG NOZZLES PREFERRED) CLOSED CONTAINERS TO PREVENT PRESSURE BLDUP
& POSSIBLE AUTOIGNIT OR EXPLOSION. WEAR SCBA.
Unusual Fire/Explosion Hazard:KEEP CONTAINER CLOSED.KEEP FROM
HEAT/ELECTRICAL EQUIP.CLOSED CONTAINER MAY EXPLODE W/HEAT.DON'T
APPLY ON HOT SURFACES.TOXIC GASES MAY FORM IF CONTACT W/FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:PROVIDE MAX VENT. ONLY PERSONNEL EQUIPPED
AREA. REMOVE IGNITION SOURCE. TAKE UP SPILL W/SAWDUST, VERMICULITE,
OR OTHER ABSORBENT & P LACE INTO CONTAINERS FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. STORE LRG QTY
IN BLDGS DESIGNED & PROTECTED FOR STORAGE OF NFPA CLASS 1B
FLAMMABLE LIQUIDS.
Other Precautions:IF MATERIAL IS PART OF MULTIPLE COMPONENT COATING
SYSTEM, READ MSDS FOR OTHER COMPONENTS BEFORE BLENDING AS RESULTING
MIXTURE MAY HAVE HAZARDS OF ALL PARTS. CONTAINERS SHOULD BE
GROUNDED WHEN POURING. AVOID FREE FALL OF LIQ >FEW INCHES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:OVEREXPOSURE TO VAPOR MAY BE PREVENTED BY
ENSURING VENT CONTROLS,VAPOR EXHAUST OR FRESH AIR ENTRY. NIOSH/MSHA
(TC 23C) PAINT SPRAY OR AIR SUPPLIED (TC-19C) RESPIRATORS MAY ALSO
REDUCE EXPOSURE. READ R ESP MFR INSTRUCTIONS FOR TYPE OF RSPRTR.
Ventilation:GENERAL DILUTION OR LOCAL EXHAUST VENT TO KEEP
CONCENTRATION OF INGREDIENTS BELOW LOWEST TLV/PEL & LEL.
Other Protective Equipment:WEAR PROTECTIVE CLOTHING,INCLUDING
IMPERMEABLE APRON CONSTRUCTED OF NITRILE RUBBER,NEOPRENE RUBBER OR
POLYVINYL ALCOHOL.
Work Hygienic Practices:CLEAN OR DISCARD CONTAMINATED CLOTHING AND
SHOES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:56 TO 192C
Vapor Pres:81.8 MM HG
Vapor Density:> AIR
Spec Gravity:0.79
Evaporation Rate & Reference:405 (BUOAC=100)
Solubility in Water:20.2%
Percent Volatiles by Volume:100.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG ALKALIES, STRONG MINERAL ACIDS, OR STRONG
OXIDIZING AGENTS.
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS DECOMPOSITION
PRODUCTS WHEN HEATED, INCLUDING: CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MUST BE DISPOSED OF IN ACCORDANCE WITH
FEDERAL, STATE, AND LOCAL ENVIRONMENTAL CONTROL REGULATIONS. EMPTY
CONTIANERS SHOULD BE RECYCLED OR DISPOSED OF THROUGH AN APPROVED
WASTE MANAGEMENT FACILI TY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LIM - LIQUID ICE MACHINE CLEANER 13 OZ BOTTLE
Preparer's Name:TIM HEATON
CAGE:ACESU
CAGE:ACESU
============= Composition/Information on Ingredients =============
Ingred Name:PHOSPHORIC ACID
CAS:7664-38-2
RTECS #:TB6300000
Fraction by Wt: >50%
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/CUM
ACGIH TLV:1 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CORROSIVE. CAUSES BURNS TO EYES, SKIN
& RESPIRATORY TRACT. INHALATION: IRRITATION OF NOSE & THROAT.
SKIN/EYES: BURNING & IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, BURNING, GASTRIC DISTRESS.
======================= First Aid Measures =======================
First Aid:EYES: WASH W/PLENTY OF WATER FOR 15 MINS. SKIN: WASH WELL
W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION: DRINK
WATER. DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL, WATER FOG, CO2
Fire Fighting Procedures:WEAR SCBA.
Unusual Fire/Explosion Hazard:REACTS W/OXIDIZERS, CHLORINATING AGENTS &
MOST METALS.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: DILUTE & WASH TO DRAIN. LARGE: CAN'T
OCCUR.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:KEEP THIS & ALL CHEMICALS OUT OF REACH OF CHILDREN.
AVOID CONTACT W/EYES & SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NEEDED IN MISTING APPLICATION TO KEEP TLV BELOW
LIMITS.
Ventilation:LOCAL EXHAUST VENTILATION.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:275F
Vapor Pres:15
Vapor Density:>1
Spec Gravity:1.4
Evaporation Rate & Reference:(WATER =1): >1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIQUID W/NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALINE & ALKALINE MATERIALS, OXIDIZERS, CHLORINATING AGENTS, METALS.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DEPOSIT IN LAND FILL IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-C-46168D, TYPE II, 37038
Kit Part:Y
CAGE:33461
CAGE:33461
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL-3-ETHOXYPROPIONATE
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 25%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:150 PPM
ACGIH TLV:150 PPM/200STEL;9394
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ISOBUTYL KETONE (HEXONE) (SARA III)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:50 PPM/75 STEL; 9394
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPYLENE GLYCOL MONOMETHYL ETHER ACETATE
CAS:108-65-6
RTECS #:AI8295000
Fraction by Wt: <0.1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPN
Ingred Name:DIBUTYL TIN DILAURATE
CAS:77-58-7
RTECS #:WH7000000
Fraction by Wt: <0.1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S, 0.1 MG/M3;(SN)
ACGIH TLV:S, 0.1 MG/M3;(SN) 91
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION-IRRITATION OF THE
RESPIRATORY TRACT & ACUTE NERVOUS SYSTEM DEPRESSION. SKIN &
EYE-CONTACT WITH THE SKIN CAN CAUSE IRRITATION. INGESTION-CAN
RESULT IN IRRITATION & POSSIBLE CORROSIVE ACTION IN THE MOUTH,
STOMACH TISSUE & DIGESTIVETRACT.
Explanation of Carcinogenicity:NONE OF THE LISTED HAZARDOUS INGREDIENTS
ARE LISTED AS CARCINOGENS BY NTP, IARC MONOGRAPHS OR OSHA.
Effects of Overexposure:INHALATION-HEADACHE, DIZZINESS, STAGGERING
GAIT, CONFUSION, UNCONSCIOUSNESS OR COMA. SKIN-SWELLING, REDNESS,
RASH. EYE-TEARING, REDNESS, SWELLING ACCOMPAINED BY A STINGING
SENSATION. INGESTION-VOMITIN G MAY CAUSE ASPIRATION OF THE SOLVENT
RESULTING IN CHEMICAL PNEUMONITIS.
Medical Cond Aggravated by Exposure:ASTHMA AND ANY OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA, DERMATITIS.
======================= First Aid Measures =======================
First Aid:INHALATION-MOVE TO AN AREA FREE FROM RISK OR FUTHER EXPOSURE.
RESTORE BREATHING. OBTAIN MEDICAL ATTENTION. SKIN-REMOVE
CONTAMINATED CLOTHING. WASH EFFECTED AREAS THOROUGHLY WITH SOAP &
WATER. EYES-FLU SH WITH CLEAN LUKE-WARM WATER (LOW PRESSURE) FOR AT
LEAST 15 MIN. OBTAIN MEDICAL ATTENTION. INGESTION-DO NOT INDUCE
VOMITING. DO NOT GIVE ANYTHING BY MOUTH IF UNCONSCIOUS. OBTAIN
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:60.0F,15.6C
Lower Limits:1.05
Extinguishing Media:FOAM, ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL,
WATER FOG. USE WATER TO COOL CONTAINERS, PREVENT PRESSURE BUILD-UP.
Fire Fighting Procedures:FULL FIRE FIGHTING EQUIPMENT WITH
SELF-CONTAINED BREATHING APPARATUS & FULL PROTECTIVE CLOTHING
SHOULD BE WORN BY FIRE FIGHTERS.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, SPARKS, ELECTRICAL EQUIPMENT & OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL NONESSENTIAL PERSONNEL. REMOVE
ALL SOURCES OF IGNITION (FLAME, SPARK SOURCE, HOT SURFACES).
VENTILATE AREA. CONTAIN SPILL AND REMOVE WITH INERT ABSORBENT AND
NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN BUILDINGS DESIGNED TO COMPLY
WITH OSHA 1910.106. AVOID STORING NEAR HIGH TEMPERATURES, FIRE,
OPEN FLAMES & SPARK SOURCES.
Other Precautions:STORE IN TIGHTLY CLOSED CONTAINERS. STORE IN WELL
VENTILATED AREAS. KEEP CONTAINER TIGHT AND UPRIGHT TO PREVENT
LEAKAGE. PREVENT PROLONGED OR REPEATED BREATHING OF VAPORS OR SPRAY
MISTS. PROLONGED EXP OSURE MAY CAUSE AN ALLERGIC REACTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR THAT IS RECOMMENDED OR APPROVED FOR
USE IN AN ORGANIC VAPOR ENVIRONMENT (AIR PURIFYING OR FRESH AIR
SUPPLIED) IS NECESSARY. OBSERVE OSHA REGULATIONS FOR RESPIRATOR
USE. VENTILATION SHOULD B E PROVIDED TO KEEP EXPOSURE BELOW PEL'S.
Ventilation:EXHAUST VENTILATION SUFFICIENT TO KEEP THE AIRBORNE
CONCENTRATIONS OF SOLVENT VAPORS OR MISTS BELOW THEIR RESPECTIVE
TLV
Other Protective Equipment:USE LONG SLEEVE AND LONG LEG CLOTHING.
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING OR USING WASH
ROOM. SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
AVOID CONTACT WITH SKIN AND EYES. DO NOT TAKE INTERNALLY. DO NOT HANDLE
UNTIL THE MANUFACTURES SAFETY PRECAUTIONS HAVE BEEN READ AND
UNDERSTOOD.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:=96.1C, 205.F
B.P. Text:205-338 F
Vapor Density:>AIR
Evaporation Rate & Reference:0.81 X N-BUTYL ACETATE
Appearance and Odor:BLACK LIQUID WITH SOLVENT ODOR.
Percent Volatiles by Volume:62.7
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS OR OPEN FLAMES.
Hazardous Decomposition Products:BY HIGH HEAT: CARBON MONOXIDE, CARBON
DIOXIDE, OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MUST BE DISPOSED OF IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL ENVIRONMENTAL CONTROL REGULATIONS. EMPTY
CONTAINERS MUST BE HANDLED WITH CARE DUE TO PRODUCT RESIDUE AND
FLAMMABLE VAPOR. DO NOT I NCINERATE CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:0510 ENCORE LATEX MEDIUM GLOSS EXTERIOR HOUSE & TRIM
CAGE:DALWO
CAGE:DALWO
============= Composition/Information on Ingredients =============
Ingred Name:VOLATILE ORGANIC COMPOUNDS: 1.72 LBS/GAL.
RTECS #:9999999VO
Ingred Name:NON HAZARDOUS INGREDIENTS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALTION: IRRITATION OF THE
RESPIRATORY TRACT. SKIN/EYES: PRIMARY IRRITATION. INGESTION: LARGE
AMOUNTS COULD CAUSE SERIOUS INJURY.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
Medical Cond Aggravated by Exposure:WHEN USED IN ACCORDANCE W/SAFE
HANDLING.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH THOROUGHLY
W/WATER. SKIN: WASH W/SOAP & WATER. INGESTION: DRINK 1/2 GLASSES OF
WATER TO DILUTE. DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN
ALL CASE S.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>250F
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:COOL EXPOSED CONTAINERS W/WATER. USE SCBA.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY BURST IF EXPOSED TO
EXTREME HEAT/FIRE. TOXIC GASES MAY FORM WHEN PRODUCT BURNS.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH W/WATER. ABSORB W/SAWDUST/RAGS.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T THROW/DROP CONTAINERS. CLOSE
CONTAINER AFTER EACH USE.
Other Precautions:AVOID PROLONGED CONTACT W/EYES & SKIN/BREATHING OF
SPRAY MIST/SANDING DUST. DON'T TAKE INTERNALLY. KEEP OUT OF REACH
OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR SPECIFIED FOR
PROTECTION AGAINST PAINT SPRAY MIST & SANDING DUST IN
RESTRICTED/CONFINED AREAS.
Ventilation:ADEQUATE/MECHANICAL EXHAUST MAY BE REQUIRED IN CONFINED
AREAS.
Other Protective Equipment:SAFETY GLASSES W/SIDE SHIELDS. ADEQUATE
CLOTHING TO PROTECT SKIN.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS BEFORE EATING, SMOKING/USING THE WASHROOM.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:ELEVATED TEMPS.
Hazardous Decomposition Products:CO2, CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T INCINERATE SEALED CONTAINERS. DISPOSE OF
IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DRUM 1290/1290RE, 946-180
CAGE:JO164
CAGE:JO164
CAGE:89431
============= Composition/Information on Ingredients =============
Ingred Name:SUBSTRATE (CYLINDER) (CONSISTING OF INGREDIENT 2)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ALUMINUM (SARA 313)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: >95%
OSHA PEL:15 MG/M3 DUST
ACGIH TLV:10 MG/M3 DUST
Ingred Name:COATING (CONSISTING OF INGREDIENTS 4-6)
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLYCARBONATE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:3-PINANONE, 2-HYDROXY-; (OPC COMPOUND)
CAS:10136-65-9
RTECS #:TK4586000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ORGANIC PIGMENT
CAS:32517-36-5
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50(ORAL,RAT):>5000 MG/KG
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE/SKIN/INGESTION/INHALATION
EFFECTS:NONE CURRENTLY KNOWN. CHRONIC:NO IDENTIFIED HEALTH EFFECTS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:NOT APPLICABLE. INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO
FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP) .
EYES:IMMEDIATELY FLUSH W/POTABLE WATER FOR A MINIMUM OF 15 MINUTES,
SEEK AS SISTANCE FROM MD . SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER.
CALL MD .
===================== Fire Fighting Measures =====================
Extinguishing Media:USE APPROPRIATE AGENT FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . IF FIRE IS IN THE MACHINE TREAT AS AN
ELECTRIC FIRE, DO NOT USE WATER OR FOAM.
Unusual Fire/Explosion Hazard:NONE AND NON-EXPLOSIVE.
================== Accidental Release Measures ==================
Spill Release Procedures:NOT APPLICABLE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID EXPOSURE TO HIGH TEMPERATURES.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NOT REQUIRED.
Ventilation:NOT REQUIRED.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPEC GRAV:1.2 (COATING) 2.7 AS A WHOLE (H*2O=1)
================== Physical/Chemical Properties ==================
Spec Gravity:SUPP DATA
Solubility in Water:INSOLUBLE
Appearance and Odor:THE ORGANIC FILM IS FIRMLY BONDED TO CYLINDER.
ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND STRONG ALKALIS.
Stability Condition to Avoid:TEMPERATURES ABOVE 200C (392F).
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . WASTE DRUMS DO NOT CONTAIN ANY DANGEROUS SUBSTANCES,
THEREFORE, THEY SHOULD BE DISPOSED OF IN THE SAME MANNER AS WASTE
METAL OR PLASTI C.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:AVI-MOTIVE GREASE W
CAGE:81230
CAGE:81230
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL,PETROLEUM DISTILLATES, SOLVENT-REFINED HEAVY
NAPHTHENIC (PERCENT FORINGREDIENTS 1-3)
CAS:64741-96-4
RTECS #:PY8040000
Fraction by Wt: > 80%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL,PETROLEUM DISTILLATES, HYDROTREATED HEAVY
NAPHTHENIC (PERCENT FOR INGREDIENTS 1-3)
CAS:64742-52-5
RTECS #:PY8035000
Fraction by Wt: > 80%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL,PETROLEUM DISTILLATES, HYDROTREATED HEAVY
PARAFFINIC (PERRCENT FOR INGREDIENTS 1-3)
CAS:64742-54-7
RTECS #:PY8035500
Fraction by Wt: > 80%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ADDITIVE, POLYUREACALCIUM ACETATE THICKENERS (PERCENT FOR
INGREDIENTS 4-5)
Fraction by Wt: < 20%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CALCIUM HYDROXIDE
CAS:1305-62-0
RTECS #:EW2800000
Fraction by Wt: < 20%
Other REC Limits:N/K
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:5 MG/M3; 9293
Ingred Name:2,4-DIAMINOTOLUENE(SARA III)
CAS:95-80-7
RTECS #:XS9625000
Fraction by Wt: 0.05%
Other REC Limits:N/K
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: EXPECTED TO CAUSE NO MORE THAN
MINOR EYE IRRIT. SKIN: MAY CAUSE DISCOLORATION, IRRIT AND
SENSITIZATION. PROLONGED OR FREQUENTLY REPEATED CONTACT MAY BE
HARMFUL.INHAL:NOT EXPECTED TO BE ACUTELY T OXIC BY INHAL AT ROOM
TEMP. INHAL OF THEVAPOR AT TEMPERATURES GREATER THAN 200 FOR (SIGNS
AND SYMP OF OVEREXPOSURE)
Explanation of Carcinogenicity:2,4-DIAMINOTOLUENE:NTP-ANTICIPATED
HUMANCARC, IARC-ANIMAL; CARC(GROUP 2B). MINERAL OIL PETRO
DISTILLATES,(SEE SUP DATA)
Effects of Overexposure:HLTH HAZARDS(ACUTE + CHRONIC):AIRBORNE
CCRYSTALS MAY BE HARMFUL. INGESTION:NOT EXPECTED TO BE ACUTELY
TOXIC BY INGESTION.
Medical Cond Aggravated by Exposure:N/K
======================= First Aid Measures =======================
First Aid:EYES:FLUSH IMMEDIATELY W/ FRESH H*2O FORAT LEAST 15 MIN WHILE
HOLDING THE EYELIDS OPEN.IRRIT PERSISTS, SEE A DOCTOR.SKIN:REMOVE
CONTAM CLOTH. WASH THOROUGHLY W/SOAP + H2*O.SEE DOCTOR IF IRRIT
OCCURS.I NHAL:NOT EXPECTED TO BE AN ACUTE INHAL PROBLEM; NO FIRST
AID PROCEDURES (MFR).SUPPORT BREATH (GIVE 0*2/ART RESP) INGEST:
DATA)
===================== Fire Fighting Measures =====================
Flash Point:NO DATA AVAIL
Lower Limits:N/K
Upper Limits:N/K
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:FIRES INVOLVING MAT, DON'T ENTER ANY ENCLOSED
OR CONFINED SPACE WITHOUT PROPER PROT EQUIP INCLUDING SCBA(MFR).
USE NIOSH/MSHA APVD SCBA + FULL PROT EQUIP.
Unusual Fire/Explosion Hazard:NORMAL COMB FORMS CARBON DIOXIDE + H*20
VAPOR + MAY PRODUCE OXIDES OF NITROGEN;INCOMPLETE COMB CAN PRODUCE
CARBON MONOXIDE.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP SPILLS IMMEDIATELY, OBSERVING
PRECAUTIONS IN SPECIAL PROTECTIVE INFORMATION.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:N/K
Other Precautions:GREASE CONTAMINATED W/ CRYSTALS SHOULD NOT BE HANDLED
OR USED. DO NOT WELD, HEATOR DRILL CONTR. RESIDUE MAY IGNITE W/
EXPLOSIVE VIOLENCE IF HEATED SUFFICIENTLY.CAUTION DO NOT USE
PRESSURE TO EMPTY DRU M OR EXPLOSION MAY RESULT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:HIGH TEMP > 200 F OR WHEN CRYSTALS BECOME
AIRBORNE, WEAR APPROVED RESP PROT SUCHAS AN AMMONIA/AMINE CARTRIDGE
RESP(MFR).NIOSH/MSHA APPROVED RESPIRATOR APPPROPRIATE FOR EXPOSURE
OF CONCERN.
Ventilation:NO SPECIAL VENT IS NECESSARY(MFR).CONSULT LOCAL
SAFETY/HEALTH AUTHORITIES IF ADDITIONAL GUIDANCE IS NECESSARY.
Other Protective Equipment:SKIN CONTACT CAN BE MINIMIZED BY
WEARINGIMPERVIOUS CLOTHING.
Work Hygienic Practices:N/K
Supplemental Safety and Health
SOLUBILITY IN WATER: HYDROCARBON; INSOLUBLE IN WATER. EXPLAIN OF CARC:
HYDROTREATED HEAVY NAPHTHENIC; IARC-ANIMAL CARC(GROUP 9G).
EMERGENCY FIRST AID PROCED: MED PERSONNEL BEFORE INDUCING VOMIT. IF
ME D ADVICE CANNOT BE OBTAINED TAKE PERSONAND PRODUCT TO MEDICAL
EMERGENCY CENTER/HOSPITAL.
================== Physical/Chemical Properties ==================
Decomp Temp:Decomp Text:N/K
Vapor Pres:1 MM HG
Spec Gravity:NO DATA AVAIL
Solubility in Water:SOLUBLE IN(SUP DATA)
Appearance and Odor:PURPLE GREASE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY REACT WITH STRONG OXIDIZING MATERIALS.
Stability Condition to Avoid:N/K
Hazardous Decomposition Products:NORMAL COMB FORMS CARBON DIOXIDE AND
H*20 VAPOR + MAY PRODUCE OXIDES OF NITROGEN; INCOMPLETE COMB CAN
PRODUCE CO.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE CONTAM MAT IN DISPOSABLE CONTR + DISPOSE
OF IN A MANNER CONSISTENT W/ APPLICABLE REGS. CONTACT LOCAL ENVIR
OR HLTHAUTHORITIES FOR APPROVED DISPOSAL OF MAT(MFR). DISPOSAL MUST
BE IN ACCORDANCE WT IH FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HIGH GEL REENTERABLE ENCAPSULANT,4442-3000,PART A
Kit Part:Y
CAGE:04963
CAGE:04963
CAGE:0VL34
CAGE:55203
============= Composition/Information on Ingredients =============
Ingred Name:SOYBEAN OIL/VEGETABLE OIL
CAS:8001-22-7
RTECS #:WG4862000
Fraction by Wt: 50 - 65%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYBUTADIENE POLYMER,
CAS:25655-35-0
Fraction by Wt: 30 - 45%
Other REC Limits:NONE RECOMMENDED
Ingred Name:MINERAL OIL, HYDROTREATED (MILD), HEAVY NAPHTHENIC
DISTILLATE, PETROLEUM
CAS:64742-52-5
RTECS #:PY8035000
Fraction by Wt: 5 - 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 AS OIL MIST
ACGIH TLV:5 MG/M3 AS OIL MIST
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN. ACUTE-
EYES:MAY CAUSE MILD IRRITATION. SKIN:MAY CAUSE MODERATE IRRITATION.
INHALATION:NO ADVERSE EFFECTS ARE EXPECTED FROM INHALATION
EXPOSURE. ORAL:INGESTION IS NOT A LIKELY ROUTE OF EXPOSURE TO THIS
PRODUCT. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, REDNESS, SWELLING, PAIN, TEARING,
ITCHING, DRYNESS
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF
THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:IMMEDIATELY FLUSH WITH
WATER FOR 15 MINUTES. HOLD EYELIDS OPEN. CALL PHYSICIAN. SKIN:WASH
WITH SOA P & WATER. ORAL:DO NOT INDUCE VOMITING.IF CONSCIOUS, DRINK
TWO GLASSES OF WATER. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>230F,>110C
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, SAND, FOAM/DRY
CHEMICAL. WATER SPRAY MAY BE USED TO KEEP FIRE EXPOSED CONTAINERS
COOL.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:PREVENT SKIN AND EYE CONTACT. REMOVE IGNITION
SOURCES. VENTILATE AREA. COVER WITH INORGANIC ABSORBENT MATERIAL.
COLLECT AND PLACE IN AN APPROPRIATE CONTAINER FOR DISPOSAL. WASH
SPILL SITE WITH AN APPR OPRIATE ORGANIC SOLVENT. PLACE IN CLOSED
CONTAINER
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM FLAMES AND
INCOMPATIBLE MATERIALS.
Other Precautions:WASH THOROUGHLY WITH SOAP AND WATER AFTER HANDLING
AND BEFORE EATING, DRINKING, SMOKING. KEEP OUT OF REACH OF
CHILDREN. DO NOT GET IN EYES, ON SKIN OR ON CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:ADEQUATE
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER, PROTECTIVE
CLOTHING
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT EAT/DRINK WHILE WORKING WITH THIS
PRODUCT.
Supplemental Safety and Health
KEY1:N1. THIS PRODUCT IS A KIT CONSISTING OF TWO PARTS. PART A, HAS PNI
A; PART B HAS PNI B, SAME NSN.
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NOT RELEVANT
Vapor Pres:<5 @ 68F
Spec Gravity:0.9
Viscosity:700 CPS
Solubility in Water:NIL
Appearance and Odor:CLEAR, AMBER LIQUID - MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS
Stability Condition to Avoid:OPEN FLAME AND EXTREME HEAT
Hazardous Decomposition Products:MAY FORM CARBON MONOXIDE, CARBON
DIOXIDE, OXIDES OF NITROGEN, OXIDES OF SULFUR, ALDEHYDES,
HYDROCARBONS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. INCINERATE UNCURED WASTE IN AN INDUSTRIAL
OR COMMERCIAL INCINERATOR. DISPOSE OF EMPTY CANS IN A SANITARY
LANDFILL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DR047 CONCENTRATE
CAGE:EO559
CAGE:EO559
CAGE:70506
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 61.0%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 25.0%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 11.0%
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:INHALATION-HEADACHE,NAUSEA,DIZZINESS.SKIN
CONTACT-PROLONGED OR REPEATED CONTACT MAY IRRITATE SKIN
======================= First Aid Measures =======================
First Aid:INHALATION-MOVE TO FRESH AIR.SKIN-FLUSH WITH LARGE AMOUNTS OF
WATER.REMOVE CONTAMINATED CLOTHING.EYE CONTACT-FLUSH WITH CLEAN
WATER FOR AT LEAST 15 MINUTES. CALL A PHYSICIAN
===================== Fire Fighting Measures =====================
Flash Point:43F;6.1C PMCC
Extinguishing Media:CO*2;DRY CHEMICAL;FOAM
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS
Unusual Fire/Explosion Hazard:WATER SHOULD BE USED TO COOL CONTAINERS
EXPOSED TO FIRE
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID BREATHING VAPORS,EXTINGUISH IGNITION
SOURCES IN IMMEDIATE AREA.AVOID CONTACT WITH LIQUID
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE AT ELEVATED TEMPERATURES
Other Precautions:CLOSE CONTAINERS AFTER USE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN CONFINED AREAS,USE U.S. BUR OF MINES APPROVED
RESPIRATOR
Ventilation:LOCAL-SUFFICIENT TO KEEP CONCENTRATION BELOW GIVEN TLV
Other Protective Equipment:NORMAL PROTECTIVE CLOTHING
Supplemental Safety and Health
BOILING POINT RANGE:80-173C
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:176-343F
Vapor Density:>1
Spec Gravity:1.05
Evaporation Rate & Reference:<1 ETHER
Solubility in Water:SLIGHT
Appearance and Odor:GRAY-MOBILE LIQUID CONTAINING VOLATILE SOLVENTS
Percent Volatiles by Volume:76.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS;SOFTENS RUBBER
Hazardous Decomposition Products:CO;CO*2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN CLOSED CONTAINERS-AWAY FROM
IGNITION SOURCES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SODIUM HYDROXIDE SOLUTION 0.02N TO 1N, SS27220
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE (CERCLA)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 0.08-4%
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER; WEIGHT PERCENT: 99.6-99.; LD50 (ORAL RAT): >90 ML/KG
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: >99.6%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:FIRST AID PROC: NEVER GIVE ANYTHING BY MOUTH TO AN UNCON
PERSON. GET MED AID IMMED. INHAL: REMOVE TO FRESH AIR (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3: IMMED. IF NOT BRTHG, GIVE ARTF RESP. IF BRTHG IS
DFCLT, GIVE OXYGEN. GET MED AID. NOTES TO MD: TREAT (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: SYMPTOMATICALLY AND SUPPORTIVELY. ANTIDOTE: NONE
REPORTED.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 2.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: CAUSES SEV BURNS. SKIN:
CAUSES BURNS. MAY CAUSE DEEP, PENETRATING ULCERS. INGEST: CAUSES GI
TRACT BURNS. CAUSES SEV PAIN, NAUS, VOMIT, DIARR, & SHOCK. INHAL:
IRRIT MAY LEAD TO CHEM PNEUMI T & PULM EDEMA. CAUSES SEV IRRIT OF
UPPER RESP TRACT W/COUGHING, BURNS, BRTHG DFCLTY, & POSS COMA.
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: CHRONIC: PROLONGED OR REPEATED SKIN
CONTACT MAY CAUSE DERMATITIS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IMMED FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN,
OCCAS LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. SKIN: GET MED
AID IMMED. IMMED FLUSH W/PLENTY OF SOAP & WATER FOR AT LEAST 15 MIN
WHILE RE MOVING CONTAM CLTHG & SHOES. DISCARD CONTAM CLTHG IN A
MANNER WHICH LIMITS FURTHER EXPOS. INGEST: DO NOT INDUCE VOMIT. IF
CONSCIOUS & ALERT, GIVE 2-4 CUPFULS OF MILK/WATER. (ING 3)
===================== Fire Fighting Measures =====================
Extinguishing Media:USE WATER, DRY CHEMICAL, CHEMICAL FOAM, OR
ALCOHOL-RESISTANT FOAM.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTIVE EQUIPMENT AS
INDICATED. ABSORB SPILL WITH INERT MATERIAL (E.G., DRY SAND OR
EARTH), THEN PLACE INTO A CHEMICAL WASTE CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION. DO NOT
GET IN EYES, ON SKIN, OR ON CLOTHING. DO NOT INGEST OR INHALE.
Other Precautions:STORE IN A COOL, DRY, WELL-VENTILATED AREA AWAY FROM
INCOMPATIBLE SUBSTANCES. KEEP AWAY FROM STRONG ACIDS, METALS,
FLAMMABLE LIQUIDS, AND ORGANIC HALOGENS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
29 CFR 1910.134. ALWAYS USE A NIOSH APPROVED RESPIRATOR WHEN
NECESSARY.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
AIRBORNE CONCENTRATIONS BELOW THE PERMISSIBLE EXPOSURE LIMITS.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER . WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN
CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
PH: ALKALINE. MATLS TO AVOID: DIOXIDE, & CARBON DIOXIDE; IGNITES WHEN
IN CONT W/CINNAMALDEHYDE/ZINC; & REACTS EXPLO W/MIXT OF CHLOROFORM
& METHANE. CORR TO METALS SUCH AS ALUMINUM, TIN, & ZINC AS WELL AS
TO ALLOYS SUCH AS STEEL, & MAY CAUSE FORM OF FLAM HYDROGEN GAS. EYE
PROT: & FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Vapor Pres:14
Spec Gravity:1.0
pH:SUPDAT
Evaporation Rate & Reference:>1 (ETHER=1)
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTS W/MINERAL ACIDS TO FORM CORRESPONDING SALTS; REACTS W/WEAK ACIDS
GASES LIKE HYDROGEN SULFIDE, SULFUR (SUP DAT)
Stability Condition to Avoid:INCOMPATIBLE MATERIALS, ACIDS.
Hazardous Decomposition Products:TOXIC FUMES OF SODIUM OXIDE, SODIUM
PEROXIDE FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE, AND LOCAL REGULATIONS. NOT LISTED AS A MATERIAL BANNED FROM
LAND DISPOSAL ACCORDING TO RCRA.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EPOCAST RESIN 200
CAGE:GO767
POLYMERS
CAGE:99384
CAGE:GO767
============= Composition/Information on Ingredients =============
Ingred Name:BIS PHENOL EPOXY RESIN;TLV UNKNOWN, BUT SPI ERF HAZARD
CLASS IS II.
Fraction by Wt: 100%
===================== Hazards Identification =====================
Effects of Overexposure:EFFECTS NOT NOTED, BUT AVOID EYE CONTACT,
INGEST, OR SKIN CONTACT.
======================= First Aid Measures =======================
First Aid:INHALE:REMOVE TO FRESH AIR, GIVE CPR/O*2 IF
NEED;EYES/SKIN:FLUSH W LG AMTS H*2O FOR 15 MIN;INGEST:RINSE MOUTH,
GET MEDICAL ATTENTION(HIGH POLYMER INSOLUBLE IN BODY FLUIDS, PER
MFG);MFG SUGGESTS USE DE NATURED ALCOHOL TO REMOVE FROM SKIN,THEN
WASH.
===================== Fire Fighting Measures =====================
Flash Point:>400F,>204C(COC)
Extinguishing Media:H*2O,FOAM, OR DRY CHEMICAL POWDER.
Fire Fighting Procedures:WEAR SELF-CNTD BRTHG APP H*20 SPRAY TO COOL
CONTR.
Unusual Fire/Explosion Hazard:MATL MAY/MAY NOT BURN. CONTAINER MAY
EXPLODE IN HEAT OF FIRE.FIRE MAY YIELD TOXIC GASES.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE UNPROTECTED PERSONS. ELIM IGNITION
SOURCES. STOP LEAK. H*2O SPRAY COOL CONT/DIVERT SPILL FROM
FIRE/HEAT. PROVIDE VENTILATION. ABSORB W COMMERCIAL
ABSORBENT,SHOVEL INTO METAL DRUMS:LG SPILL:DI KE W COMMERCIAL
ABSORBENT,PUMP INTO COVERED DRUMS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENT,LOW FIRE
RISK AREA. PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL CONTACT.
KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:MAINTAIN STRICT HYGIENE, AVOID PHYSICAL CONTACT,
REMOVE & WASH CONTAMINATED CLOTHING. MFG SUGGESTS USE OF PROTECTIVE
SKIN CREAMS. EXHAUST CURING OVENS TO OPEN AIR. AVOID TEMP ABOVE
150-180F.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED
Ventilation:MECHANICAL (GENERAL/LOCAL EXHAUST)
Other Protective Equipment:FULL WORK CLOTHING TO PREVENT REPEATED OR
PROLONGED CONTACT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.5
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TAN PASTE; SLIGHT ETHERAL ODOR
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
Stability Condition to Avoid:TEMP >150F WILL START EXOTHERMIC REACTION
WITH FILLER.
Hazardous Decomposition Products:NONE NOTED, BUT EXPECT CO, CO*2, H*2O.
Conditions to Avoid Polymerization:DO NOT HEAT ABOVE 150F WITHOUT
ADDITION OF HARDENER.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED CONTAINERS PENDING DISPOSAL.
HANDLE AND DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE AND LOCAL REGULATIONS. MFG SUGGESTS
INCINERATION OR BURY IN APPROVED LANDFILL, AFTER ABSORBING W
SAND;WASH RESIDUE.
| 1 | gloves_mandatory |
=======================================================
Product ID: N06617, HAYNES 617 ALLOY
Cage: 80357
Box: 9013
Resp. Party Other MSDS No.: H2071-3
=======================================================
Contractor Summary
=======================================================
Cage: 80357
Box: 9013
=======================================================
Ingredients
=======================================================
Cas: 7439-89-6
RTECS #: NO4565500
% Wt: 2MAX
------------------------------
Cas: 7439-96-5
RTECS #: OO9275000
% Wt: 0.5MAX
OSHA PEL: C5 MG/M3
ACGIH TLV: 5 MG/M3
ACGIH STEL: NOT ESTABLISHED
------------------------------
Cas: 7439-98-7
RTECS #: QA4680000
Percent by Wt: 9.
ACGIH TLV: 10 MG/M3
ACGIH STEL: NOT ESTABLISHED
------------------------------
Cas: 7440-02-0
RTECS #: QR5950000
Percent by Wt: 52.
OSHA PEL: ]
EPA Rpt Qty: 100 LBS
DOT Rpt Qty: 100 LBS
------------------------------
Cas: 7440-48-4
RTECS #: GF8750000
Percent by Wt: 12.5
OSHA PEL: 0.1 MG/M3
ACGIH TLV: 0.02 MG/M3
ACGIH STEL: NOT ESTABLISHED
------------------------------
Cas: 7440-47-3
RTECS #: GB4200000
Percent by Wt: 22.
OSHA PEL: 1 MG/M3
ACGIH TLV: 0.5 MG/M3
ACGIH STEL: NOT ESTABLISHED
EPA Rpt Qty: 1 LB
DOT Rpt Qty: 1 LB
------------------------------
Cas: 7440-21-3
RTECS #: VW0400000
% Wt: 1.2MAX
OSHA PEL: 15 MG/M3
ACGIH TLV: 10 MG/M3
ACGIH STEL: NOT ESTABLISHED
------------------------------
Cas: 7429-90-5
RTECS #: BD0330000
Percent by Wt: 1.2
OSHA PEL: 15 MG/M3
ACGIH TLV: 10 MG/M3
ACGIH STEL: NOT ESTABLISHED
------------------------------
Cas: 7440-42-8
RTECS #: ED7350000
% Wt: 0.006MAX
------------------------------
Cas: 7440-03-1
RTECS #: QT9900000
Percent by Wt: .08
------------------------------
Cas: 7440-32-6
RTECS #: XR1700000
Percent by Wt: .3
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: YES
Effects of Exposure: ACUTE: INHALATION-INHALED PARTICULATE MAY IRRITATE THE
RESPIRATORY TRACT. EXCESSIVE INHALATION OF ALUMINUM, COBALT, COPPER,
MANGANESE, NICKEL & ZINC CAN CAUSE RESPIRATORY IRRITATION, COUGH,
BRONCHITIS , CHILLS, "METAL FUME FEVER" & ASTHMA-LIKE SYMPTOMS. SKIN-SKIN
CONTACT WITH THESE MATERIALS MAY CAUSE IRRITATION & IN SOME INDIVIDUALS
AN ALLERGIC DERMATITIS WHEN ELEMENTS SUCH AS CHROME, COBALT & NIC KEL ARE
PRESENT. EYES-CONTACT WITH PARTICULATE METAL MAY INFLAME THE CONJUNCTIVA.
CHRONIC: RESPIRATORY DISEASE WITH SYMPTOMS RANGING FROM SHORTNESS OF BREATH
& COUGH TO PERMANENT DISABILITY DUE TO LOS S OF LUNG FUNCTION; "SEE OTHER
INFO"
Explanation Of Carcinogenicity: CHROMIUM AND ITS COMPOUNDS, COBALT AND IS
COMPOUNDS, AND NICKEL AND ITS COMPOUNDS ARE CLASSIFIED AS CARCINOGENS BY NTP
AND.OR IARC. WELDING FUMES-OSHA REQUIRES THAT WELDING FUMES BE CONSIDIERED AS
CAR CINOGENS BECAUSE THEY ARE CLASSIFIED BY IARC.
Signs And Symptions Of Overexposure: INGESTION OF LARGE DOSES MAY CAUSE NAUSEA,
VOMITING, AND DIARRHEA.
Medical Cond Aggravated By Exposure: INDIVIDUALS WHO MAY HAVE HAD A ALLERGIC
REACTION OR SENSITIVITY TO METAL MAY ENCOUNTER SKIN RASH OR DERMATITIS.
PERSONS WITH IMPAIRED PULMONARY FUNCTION MAY INCUR FUTHER DISABILITY.
First Aid: INHALATION-REMOVE TO FRESH AIR. IF BREATHING HAS STOPPED, PERFORM
ARTIFICIAL RESPIRATION & OBTAIN MEDICAL AID AT ONCE. INGESTION-NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. CONTACT A POISONCONTROL CENTER
(PCC). UNLESS THE PCC ADVISES ORTHERWISE, HAVE CONSCIOUS PERSON DRINK 1-2
GLASSES OF WATER TO DILUTE. DO NOT INDUCE VOMITING UNLESS LARGE AMOUNTS ARE
INGESTED. OBTAIN MEDICAL AID AT ON CE. SKIN-TREAT CUTS & ABRAISIONS WITH
STANDARD FIRST AID. IF IRRITATION OCCURS, OBTAIN MEDICAL AID. EYES-FLUSH
DUST/POWDER FROM EYES WITH CLEAN WATER FOR 15 MINS. IF IRRITATION PERSISTS,
OBTAIN MEDICA L AID.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: IN SOLID FORM THIS MATERIAL POSES NO SPECIAL CLEAN-UP
PROBLEMS. IF THIS MATERIAL IS IN POWDER OR DUST FORM, DO NOT DRY SWEEP,
NOTIFY SAFETY PERSONNEL, CLEAN-UP SHOULD BE CONDUCTED WITH A VACUUM SYSTEM
UTILIZING A HIGH EFFICIENCY PARTICULATE AIR (HEPA) FILTRATION SYSTEM.CAUTION
SHOULD BE TAKEN TO MINIMIZE AIRBORNE GENERATION OF POWDER OR DUST AND AVOID
CONTAMINATION OF AIR AND WATER.
Waste Disposal Methods: WHENEVER POSSIBLE, RECOVER ALLOYS FOR REUSE OR
RECYCLING. IF NECESSARY, DISPOSE OF WASTE MATERIAL IN ACCORDANCE WITH LOCAL
STATE OR FEDERAL REGULATIONS. FOR SPECIFIC LABELING, PACKING, STORAGE, TRANSP
ORTATION AND DISPOSAL PRECEDURES, CONTACT AN ENVIRONMENTAL ENGINEER OR
CONSULTANT FAMILIAR WITH WAST E DISPOSAL REGULATIONS.
Handling And Storage Precautions: HANDLING-THIS PRODUCT MUST BE HANDLED
ACCORDING TO THE SIZE, SHAPE AND QUANTITY OF MATERIAL INVOLVED. POWDERS
SHOULD BE MOVE OR TRANSPORTED TO MINIMIZE SPILL OR RELEASE POTENTIAL. AVOID
DUST INHALATIO N AND EYE OR SKIN CONTACT.
Other Precautions: STORAGE-IN SOLID FORM THIS MATERIAL POSES NO SPECIAL
PROBLEMS. STORE METAL POWDER IN A DRY AREA AWAY FROM HEAT, IGNITION SOURCES
AND INCOMPATIBLES. **SPILL-CLEANUP PERSONNEL SHOULD PROTECT AGAINST DUS T
INHALATION & SKIN OR EYE CONTACT. USE NON-SPARKING TOOLS. PROPERLY LABEL
ALL MATERIALS COLLECTED I N WASTE CONTAINER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONE
Lower Limits: NONE
Upper Limits: NONE
Extinguishing Media: THESE ALLOYS IN SOLID WROUGHT FORM ARE NONCOMBUSTIBLE. USE
EXTINGUISHING MEDIA APPROPRIATE TO THE SURROUNGING FIRE.
Fire Fighting Procedures: TO EXTINGUISH A METAL POWDER FIRE USE DRY SAND, DRY
GRAPHITE OR OTHER CLASS "D" EXTINGUISHING POWDER.
Unusual Fire/Explosion Hazard: NO UNUSUAL FIRE OR EXPLOSION HAZARDS.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH APPROVED RESPIRATORS AS SPECIFIED BY AN
INDUSTRIAL HYGIENIST OR QUALIFIED SAFETY PROFESSIONAL. LUNG FUNCTIONS TESTS
ARE RECOMMENDED FOR USERS OF NEGATIVE PRESSURE DEVICES. USE A FUME RESPIRA
TOR OR AN AIR SUPPLIED RESPIRATOR WHERE LOCAL EXHAUST OR VENTILATION DOES NOT
KEEP EXPOSURE BELOW THE OSHA LIMITS FOR AIR CONTAMINATION.
Ventilation: LOCAL EXHAUST VENTILATION SHOULD BE USED TO CONTROL EXPOSURE TO
AIRBORNE DUST AND FUME EMISSIONS NEAR THE SOURCE BELOW THE EXPOSURE LIMITS
CITED.
Other Protective Equipment: PROTECTIVE CLOTHING SUCH AS UNIFORMS, DISPOSABLE
COVERALLS, SAFETY SHOES, ETC.
Work Hygienic Practices: PRACTICE GOOD PERSONAL HYGIENE AFTER HANDLING DUST OR
POWDER FORMS OF THIS MATERIAL, ESPECIALLY BEFORE EATING, DRINKING, SMOKING OR
APPLYING COSMETICS.
Supplemental Safety and Health: IF PRIOR DAMAGE OR DISEASE TO THE NEUROLOGIC
(NERVOUS), CIRCULATORY, HEMATOLOGIC (BLOOD) OR RENAL (KIDNEY) SYSTEMS HAS
OCCURRED, PROPER SCREENING OR EXAMINATIONS SHOULD BE CONDUCTED ON INDIVIDUALS
WHO MAY BE EXPOSED TO FURTHER RISK IF HANDLING AND USE OF THESE MATERIAL
CAUSE EXCESSIVE EXPOSURE.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
Melt/Freeze Pt: =-1367.6C, ######F
Vapor Pres: NA
Vapor Density: NA
Spec Gravity: 0.302
PH: NA
Viscosity: NA
Evaporation Rate & Reference: NA
Solubility in Water: NONE
Appearance and Odor: SOLID-SILVER GRAY COLOR OR NO COLOR
Percent Volatiles by Volume: NONE
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: THESE ALLOYS ARE STABLE MATERIALS.
Materials To Avoid: AVOID CONTACT WITH MINERAL ACIDS AN OXIDIZING AGENTS WHICH
MAY GENERATE HYDROGEN GAS; THE EVOLUTION OF HYDROGEN MAY BE AN EXPLOSION
HAZARD.
Hazardous Decomposition Products: VARIOUS ELEMENTAL METALS & METAL OXIDES MAY
BE GENERATED FROM WELDING, CUTTING, GRINDING, MELTING OR DROSS HANDLING
OPERATIONS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: DOES NOT OCCUR.
=======================================================
Toxicological Information
=======================================================
Toxicological Information: TOXICITY DATA: LD50 RAT (COBALT): 6171 MG/KG.
TERATOLOGY: RAT (NICKEL) ORAL: TDLO: 158 MG/KG. RAT (MOLYBDENUM) ORAL: 5800
MG/KG GIVEN TO FEMAL 30 WEEKS PRIOR TO MATING AND DURING DAYS 1-20 OF
PREGNACY CAUSED SPECIFIC MUSCULOSKELETAL SYSTEM DEVELOPMENT ABNORMALITIES.
REPRODUCTION: RAT (MOLYBDENUM) ORAL 6050 MG/KG. GIVEN TO FEMAL 35 WEEKS PRIOR
TO MATING PRODUCED PRE-, AND POST-IMPLANTATION MORTALI TY. RAT (COBALT)
UNSPECIFIED EXPOSURE ROUTE, O.05 MG/KG CONTINUOUS, ADMINISTERED THROUGHOUT
GASTATION TO FEMALE WAS EMBRYOTOXIC. MUTAGENICITY: HAMSTER (CHROMIUM III)
LUNG CELL: 34 MG/L CAUSED SISTER CHROMATID EXCHANGE.
=======================================================
Ecological Information
=======================================================
Ecological: ECOTOXICITY: FEW PLANTS ACCUMULATE COBALT AT GREATER THAN 100 PPM,
THE LEVEL AT WHICH SEVERE PHYTOXICITY WOULD OCCUR. THERE IS LITTLE TENDENCY
FOR CHROMIUM III BIOACCUMULATION ALONG THE FOOD CHAIN. MO LYBDENUM: FATHEAD
MINNOW), LC50: 370 MG/L/96 HOURS. TERRESTRIAL PLANTS CAN CONTAIN ENOUGH
MOLYBDENUM TO BE TOXIC TO ANIMALS BUT STILL GROW NORMALLY. ENVIONMENTAL
DEGRADATION: IN WATER, COBALT IS ADSO RBED GREATLY TO HYDROLYSATE OR OXIDATE
SEDIMENTS. IT MAY BE TAKEN INTO SOLUTION IN SMALL AMOUNTS THROUGH
BACTERIOLOGICAL ACTIVITY.
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: CHEMICALS SUBJECT TO THE REPORTING REQUIREMENTS OF
SECTION 313 OR TITLE II OF SARA AND 40 CFR PART 372: ALUMINUM (AS A FUME OR
DUST), CHROMIUM, COBALT, COPPER, MANGANESE, NICKEL (AS A POWDER OR DUST),
VANADIUM (AS A FUME OR DUST). SARA HAZARD CATERGORY: IMMEDIATE HAZARD AND
DELAYED HAZARD.
Federal Regulatory Information: OSHA: LISTED AS AN AIR CONTAMINANT (29 CFR
1910.1000). HAZAEDOUS BY DEFINITION OF HAZARD COMMUNICATION STANDARD (29 CFR
1910.1200). TSCA (TOXIC SUBSTANCE CONTROL ACT): COMPONENTS OF THIS MATERIAL
ARE LISTED ON THE TSCA INVENTORY.
CERCLA: HAZARDOUS SUBSTANCE (40 CFR 302.4): CHROMIUM (AS A POWDER): NICKEL (AS
A POWDER OR DUST). EXTREMELY HAZARDOUS SUBSTANCE (40 CFR 355): NOT LISTED.
State Regulatory Information: CALIFORNIA'S "SAFE DRINKING WATER & TOXIC
ENFORCEMENT ACT OF 1986" (PROPOSITION 65): DURING WELDING, THERMAL CUTTING
AND MELTING THESE PRODUCTS MAY PRODUCE COBALT OXIDE, NICKEL COMPOUNDS, AND
HEXAVALE NT CHROMIUM COMPOUNDS WHICH ARE KNOWN TO THE STATE OF CALIFORNIA TO
CAUSE CANCER. PENNSYLVANIA WORKER AND COMMUNITY RIGHT TO KNOW: ALUMINUM,
CHROMIUM AND VANADIUM (FUME OR DUST) ARE DESIGNATED ENVIRO NMENTAL HAZARDS ON
THE HAZARDOUS SUBSTANCE LIST. TITLE 34, PART XIII, CHAPTER 323.
=======================================================
Other Information
=======================================================
Other Information: HEALTH HAZARD: CENTRAL NERVOUS SYSTEM DEPRESSION HAS BEEN
IDENTIFIED WITH EXCESSIVE MANGANESE EXPOSURE. INSOLUBLE NICKEL COMPOUNDS
& HEXAVALENT CHROMIUM COMPOUNDS HAVE BEEN LINKED TO NASAL, BRONCHIAL
& LUNG CANCER. ALUMINUM AND IRON HAVE BEEN INDICATED TO CAUSE
GASTRO-INTESTINAL DISORDERS AND NON-SIGNIFICANT CHANGES IN THE LUNG. CHRONIC
HEALTH EFFECTS SPECIFIC TO AN ELEMENT(S) MAY BE DIFFICULT TODETECT DUE TO
THE NUMEROUS ELEMENTAL CONSITIUENTS IN THESE ALLOYS.
=======================================================
Transportation Information
=======================================================
Trans ID NO: 160234
Product ID: N06617, HAYNES 617 ALLOY
Review Date: 12/12/2001
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: CY
Type Of Container: CYLINDER
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: N06617, HAYNES 617 ALLOY
Cage: 80357
Company Name: HAYNES INTERNATIONAL INC SUB OF CABOT CORP
Street: 1020 W PARK AVE
PO Box: 9013
Zipcode: 46904-9013
Label Required IND: Y
Date Of Label Review: 12/12/2001
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: NONE
Respiratory Protection IND: YES
Health Hazard: None
Contact Hazard: None
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: DANGER! INHALATION OF DUST OR FUME MAY CAUSE SERIOUS
LUNG INJURY, SKIN, EYE & MUCOUS MEMBRANE IRRITATION MAY OCCUR. *ACUTE:
INHALATION-INHALED PARTICULATE MAY IRRITATE THE RESPIRATORY TRACT. EXCESSIVE
INHALATION OF ALUMINUM, COBALT, COPPER, MANGANESE, NICKEL & ZINC CAN
CAUSE RESPIRATORY IRRITATION, COUGH, BRONCHITIS, CHILLS, "METAL FUME FEVER"
& ASTHMA-LIKE SYMPTOMS. SKIN-SKIN CONTACT WITH THESE M ATERIALS MAY CAUSE
IRRITATION & IN SOME INDIVIDUALS AN ALLERGIC DERMATITIS WHEN ELEMENTS
SUCH AS CHROME, COBALT & NICKEL ARE PRESENT. EYES-CONTACT WITH
PARTICULATE METAL MAY INFLAME THE CONJUNCTIVA.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DURABLA BLACK
CAGE:JO980
CAGE:85130
CAGE:72021
CAGE:JO980
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS (FRIABLE)(SARA III)
CAS:1332-21-4
RTECS #:CI6425000
Fraction by Wt: 80%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE 1910.1001
ACGIH TLV:0.2 - 2 FIBERS/CC
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:STYRENE BUTADIENE
CAS:9003-54-7
Fraction by Wt: 20%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE:MINOR EYS/SKIN IRRITATION.
INGESTION- IRRITATION OF GI TRACT. INHALATION-IRRITATION OF
RESPIRATORY TRACT. CHRONIC: ASBESTOSIS, LUNG CANCER, &
MESOTHELIOMA, ALL OF WHICH ARE DISABLING AND FATAL D ISEASES OF THE
LUNG. INHALATION AND INGESTION OF ASBESTOS FIBERS MAY CAUSE CANCER
OF THE BOWEL.
Explanation of Carcinogenicity:THIS PRODUCT CONTAINS A
[1332-21-4], AN OSHA REGULATED CARCINOGEN.
Effects of Overexposure:INHALATION: FATIGUE AND SHORTNESS OF BREATH
THAT GETS WORSE WITH TIME AND EVENTUALLY BECOMES DISABLING. EYES:
IRRITATION. SKIN: IRRITATION. INGESTION: MILD STOMACH DISTRESS.
DIARRHEA, VOMITING, AND NA USEA.
Medical Cond Aggravated by Exposure:ASTHMA, EMPHYSEMA, AND TUBERCULOSIS
ARE ALL GENERALLY AGGRAVATED BY EXPOSURE TO ASBESTOS FIBERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SEE DOCTOR. EYES: RINSE
THOROUGHLY WITH WATER FOR 15 MINUTES. SEE DOCTOR. SKIN: WASH
THOROUGHLY WITH SOAP AND WATER. IF IRRITATION PERSISTS, SEE DOCTOR.
INGESTION: DIL UTE WITH WATER. DO NOT INDUCE VOMITING.SEE DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:NOT REQUIRED
Extinguishing Media:MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM THE MATERIAL WITH A HEPA FILTERED
VACUUM. THE EQUIPMENT SHALL BE USED & EMPTIED SO AS TO MINIMIZE THE
RE-ENTRY OF ASBESTOS INTO THE WORKPLACE. OTHERWISE, WET THE
MATERIAL WITH WATER & SURFACTAN T AND THEN SHOVEL OR MOP UP
CONTAMINATION.
======================Handling and Storage ======================
Handling and Storage Precautions:ITEM IS NONFRIABLE & WILL NOT SHED
FIBERS IN NORMAL USE AND STORAGE. USED ITEMS SHALL BE WETTED
BEFORE, DURING & AFTER DISASSEMBLY.
Other Precautions:IF IT IS NECESSARY TO CUT OR IMPACT THE ITEM WHILE
INSTALLING IT, WEAR A RESPIRATOR AND PROTECTIVE CLOTHING. USED
ITEMS SHALL BE IDENTIFIED AND DISPOSED OF IN ACCORDANCE WITH ALL
LOCAL, STATE AND FEDE RAL REGULATIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED HEPA RESPIRATOR IF
REQUIRED. WEAR SELF-CONTAINED BREATHING APPARATUS IF REQUIRED FOR
HIGH LEVELS OF CONTAMINATES.
Ventilation:LOCAL EXHAUST SUFFICIENT TO ENTRAIN ALL PARTICULATE
EMISSIONS. HEPA FILTER REQUIRED. NO LEAKS ON PRESSURE SIDE OF FAN.
Other Protective Equipment:USE COVERALLS OR DISPOSABLE CLOTHING.
Work Hygienic Practices:WET WORK TO THE DEGREE POSSIBLE. WASH HANDS
AFTER HANDLING ITEM. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:T6
Spec Gravity:1.92 (WATER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK OR SLATE GREY
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG MINERAL ACIDS, AND STRONG ALKALIS
Stability Condition to Avoid:ACCUMULATIONS OF DUST
Hazardous Decomposition Products:ASBESTOS DUST
==================== Disposal Considerations ====================
Waste Disposal Methods:WET THE MATERIAL WITH WATER AND SURFACTANT.
PLACE IN 6 MIL THICK POLYETHYLENE PLASTIC BAG. PLACE THESE BAGS
INTO ANOTHER POLY BAG OR A SAFE PLACE UNTIL IT CAN BE SHIPPED TO AN
APPROVED DISPOSAL SITE. IDENTIFY WITH ASBESTOS CANCER WARNING
LABEL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TT-E-2784
Preparer's Name:ONEY FLEMING
CAGE:JO954
CAGE:JO954
CAGE:39934
============= Composition/Information on Ingredients =============
Ingred Name:PROPYLENE GLYCOL
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: 3.82%
Other REC Limits:NONE RECOMMENDED
Ingred Name:2,2,4-TRIMETHYL-1-3-PENTANEDIOL MONOISOBUTYRATE
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: 3.53%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIMETHYLAMINOETHANOL LOW VOC
CAS:108-01-0
RTECS #:KK6125000
Fraction by Wt: 0.22%
Other REC Limits:NONE RECOMMENDED
Ingred Name:2-N-OCTYL-4-ISOTHIAZOLIN-3-ONE
CAS:26530-20-1
Fraction by Wt: 0.18%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NON HAZARDOUS INGREDIENTS
Fraction by Wt: 92.25%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CAN CAUSE IRRITATION OF RESPIRATORY
PASSAGES.
Effects of Overexposure:INHALATION OF VAPOR/MIST CAN CAUSE HEADACHES,
NAUSEA, IRRITATION OF NOSE/THROAT/LUNGS. EYES: CAN CAUSE SLIGHT
IRRITATION. CHRONIC SKIN CONTACT CAN CAUSE SLIGHT IRRITATION.
Medical Cond Aggravated by Exposure:PREEXISTING LUNG DISEASE MAY BE
AGGRAVATED BY EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LARGE AMTS WATER 15 MINUTES. CONSULT DR. IF
IRRITATION PERSISTS. SKIN: WASH AFFECTED AREA THOROUGHLY W/SOAP &
WATER. INGESTION: GIVE 2 GLASSES WATER. CONSULT DR.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>212F,>100C
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR SCBA (PRESSURE DEMAND MSHA/NIOSH APPROVED
OR EQUIVALENT) & FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:MATERIAL CAN SPLATTER ABOVE 212F/100C.
POLYMER FILM CAN BURN.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP SPECTATORS AWAY. FLOOR MAY BE SLIPPERY.
USE CARE TO AVOID FALLING. CONTAIN W/INERT MAT'L (SAND/EARTH).
TRANSFER LIQ/SOLID DIKING MAT'L TO SEPARATE SUITABLE CONTAINERS FOR
RECOVERY/DISPOSAL.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING. DO NOT TAKE
INTERNALLY. KEEP AWAY FROM CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:APPROVED MECHANICAL FILTER RESPIRATOR TO REMOVE
SOLID AIRBORNE PARTICLES OF OVER-SPRAY DURING SPRAY APPLICATION.
Ventilation:NORMAL, SUCH AS FAN.
Other Protective Equipment:EYEWASH STATION.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212 TO 644F
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Decomp Temp:Decomp Text:350F,177C
Vapor Pres:NONE
Vapor Density:>AIR
Spec Gravity:1.12
VOC Pounds/Gallon:194
pH:9 MAX
VOC Grams/Liter:1.62
Viscosity:77-95 KU
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT
Appearance and Odor:OLIVE DRAB LIQUID, SLIGHT ODOR
Percent Volatiles by Volume:60.6
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:ACRYLIC MONOMERS
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP SPILLS/CLEANING RUN-OFF OUT OF SEWERS &
OPEN BODIES OF WATER. CONSULT FEDERAL/STATE/LOCAL AUTHORITIES FOR
PROPER DISPOSAL PROCEDURES CONCERNING HEALTH & ENVIRONMENT.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AQUASOL E DROPS
CAGE:04473
CAGE:04473
============= Composition/Information on Ingredients =============
Ingred Name:TOCOPHERYL ACETATE *95-1*
CAS:7695-91-2
RTECS #:GA8747000
Fraction by Wt: 5.4%
Ingred Name:POLYSORBATE 80 USP, POLYOXYETHYLENESORBITOL OLEATE, TWEEN
80
CAS:9005-65-6
RTECS #:WG2932500
Fraction by Wt: 25%
Ingred Name:1,2-PROPANEDIOL (PROPYLENE GLYCOL)
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: 19.3%
Ingred Name:ARTIFICIAL ANISE OIL
Fraction by Wt: 0.4%
Ingred Name:ARTIFICIAL BUTTERSCOTCH
Fraction by Wt: 0.6%
Ingred Name:SODIUM SACCHARINE, SODIUM SACCHARIN (SUSPECTED ANIMAL CARC
BY IARC GRP 2B & NTP) * 95-1 *
CAS:128-44-9
RTECS #:DE4550000
Fraction by Wt: 0.15%
Ingred Name:SORBITOL
CAS:50-70-4
RTECS #:LZ4290000
Fraction by Wt: 20%
Ingred Name:ALKALI OIL
Fraction by Wt: TRACE
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (MOUSE): 25000 MG/KG (SUPP)
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE IRRITATION & CAN BE ABSORBED
THROUGH THE SKIN.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:MAY CAUSE IRRITATION & CAN BE ABSORBED THROUGH
SKIN.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/PLENTY OF WATER FOR 15 MINS. SKIN;
WASH EXPOSED AREA W/SOAP & WATER. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, ALCOHOL FOAM, CO2.
Fire Fighting Procedures:USE MEDIA SUITABLE FOR SURROUNDING MATERIALS.
================== Accidental Release Measures ==================
Spill Release Procedures:USE DRY ABSORBENT & PLACE INTO CLOSED WASTE
CONTAINER DESTINED FOR STANDARD INCINERATION.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT CONTROLLED ROOM TEMPERATURE
OF 59-88F. DON'T INGEST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL & INTENDED USES.
Ventilation:GENERAL ROOM.
Other Protective Equipment:EMERGENCY EYE BATH
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
PHARMACEUTICAL PRODUCT USED FOR PREVENTION &/TREATMENT OF VITAMIN E
DEFICIENCY. ORAL LD50 INFORMATION IS FOR POLYSORBATE 80.
================== Physical/Chemical Properties ==================
Solubility in Water:COMPLETE
Appearance and Odor:PALE YELLOW LIQUID W/NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:TOXIC GASES & VAPORS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PLCA2-3X, CUSTOM PLASMA STANDARD 10,000 PPM (SUPDAT)
Preparer's Name:VANAJA SIVAKUMAR
CAGE:IO043
CAGE:04XT3
CAGE:IO043
============= Composition/Information on Ingredients =============
Ingred Name:NITRIC ACID; (HNO*3) (SARA 302/313) (CERCLA)
CAS:7697-37-2
RTECS #:QU5775000
Fraction by Wt: 2-5%
OSHA PEL:2 PPM
ACGIH TLV:2 PPM;4 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:CALCIUM CARBONATE; (CACO*3). %:0.25-2.5. LD50:(ORAL,RAT)
6450 MG/KG.
CAS:471-34-1
RTECS #:FF9335000
Fraction by Wt: <2.5%
OSHA PEL:N/K
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 90-97%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPP DATA:CAUSE VIOLENT SPLATTERING.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP:CONC SOLNS CAUSE DEEP ULCERS & STAIN SKIN
BRIGHT YELLOW/YELLOWISH BROWN COLOR. VAP & MIST MAY (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:ERODE EXPOS TEETH W/PRLNG EXPOS. INGEST OF LIQ WILL
CAUSE IMMED PAIN & BURNS OF MOUTH, ESOPHAGUS & GI (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:TRACT. INHAL MAY BE FATAL CAUSING SPASM, INFLAMM &
EDEMA OF THE LARYNX & BRONCHI, CHEM PNEUM & PULM EDEMA. (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:SYMPS INCL; BURNING SENSATION, COUGHING, WHEEZING,
LARYNGITIS, SHORTNESS OF BREATH, HEADACHE, NAUSEA & VOMITING.
RTECS #:9999999ZZ
Ingred Name:EYE PROT:& FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 2.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SYMPS & HLTH HAZS FOR DILUTE NITRIC
ACID ARE EXPECTED TO BE LESS SEV THAN EXPOS TO CONC NITRIC ACID.
HOWEVER, SINCE NITRIC ACID IS IN SOLN AT 1% (OR 10,000 PPM) OR
GREATER, HLTH HAZS FOR CONC NITRIC A CID ARE GIVEN. THIS SOLN IS
HARMFUL IF INHALED, INGESTED/CONTACTED W/SKIN OR EYES. CALCIUM
CARBONATE IS(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:SEV TO MOD SKIN IRRIT. CONC NITRIC
ACID MAY BE FATAL IF TOO MUCH IS INHALED/ABSORBED THRU SKIN. CONC
NITRIC ACID VAP/MIST IS IRRIT OF EYES, MUC MEMBS & SKIN. IN CONT
W/EYES, IT PRDCES SEV BUR NS WHICH MAY RSLT IN PERM DMG & VISUAL
IMPAIRMENT. ON SKIN, LIQ/CONC VAP PRDCES IMMED, SEV & PENETRATING
BURNS; (ING 5)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER FOR AT LEAST 15 MINUTES OCCASIONALLY
LIFTING UPPER & LOWER EYELIDS. SKIN:REMOVE CONTAMINATED
CLOTHING,THEN FLUSH W/WATER FOR AT LEAST 15 MINUTES. WASH CLOTHING
THOROUGHLY BEFORE REU SE. INHAL:MOVE TO FRESH AIR. IF IRRITATION
CONTINUES, GET MEDICAL ATTENTION IMMEDIATELY. INGEST:GET MEDICAL
ATTENTION IMMEDIATELY. IF THE VICTIM IS CONSCIOUS, GIVE LARGE
AMOUNTS OF WATER OR MILK.
===================== Fire Fighting Measures =====================
Extinguishing Media:APPROPRIATE TO SURROUNDING FIRE CONDITIONS.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CONC HNO*3 IS NOT COMBUST, BUT IS STRONG
OXIDIZER & ITS HEAT OF RXN W/REDUCING AGENTS/COMBUSTS MAY CAUSE
IGNIT. CAN REACT W/METALS TO RELS FLAMM (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA. DILUTE SPILL W/WATER & NEUT W/SODA
ASH, LIMESTONE, ETC. WIPE UP & PUT INTO SEALED CNTNR FOR PROPER
DISPOSAL. WASH SPILL SITE OFF W/WATER AFTER MATL PICK UP IS
APPROVED RESP.
Neutralizing Agent:SODA ASH, LIMESTONE, ETC.
======================Handling and Storage ======================
Handling and Storage Precautions:CONCENTRATED NITRIC ACID WILL ATTACK
SOME FORMS OF PLASTICS, RUBBER & COATINGS. STORE AT ROOM
TEMPERATURE. KEEP TIGHTLY SEALED WHEN NOT IN USE.
Other Precautions:IRRITANT, OXIDIZER & CORROSIVE LIQUID. AVOID
INHALATION, INGESTION & CONTACT W/EYES & SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH APPROVED RESPIRATOR.
Ventilation:USE IN A CHEMICAL FUME HOOD.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . LAB COAT. WEAR CHEMICAL RESISTANT CLOTHING.
Work Hygienic Practices:WASH CAREFULLY AFTER USE.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:OF CALCIUM IN 5% NITRIC ACID. EXPLO
HAZ:HYDROGEN GAS. CONC HNO*3 REACTS EXPLO W/COMBUST ORG/READILY
OXIDIZABLE MATLS SUCH AS; ALCOHOL, WOOD, TURPENTINE, METAL PWDRS,
HYDROGEN SULFIDE, ETC. MATLS TO AVOID:WOOD, TURPENTINE, METAL
PWDRS, HYDROGEN SULFIDE, ETC. CONT W/STRONG BASES WILL (ING 4)
================== Physical/Chemical Properties ==================
Spec Gravity:1
Solubility in Water:SOLUBLE
Appearance and Odor:TRANSPARENT W/ACRID ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONC HNO*3 IS POWERFUL OXIDIZING AGENT. IT REACTS EXPLO W/COMBUST
ORG/READILY OXIDIZABLE MATLS SUCH AS; ALCOHOL,(SUPDAT)
Stability Condition to Avoid:ELEVATED TEMPERATURES MAY CAUSE CONTAINERS
TO BURST & LIBERATE TOXIC OXIDES OF NITROGEN.
Hazardous Decomposition Products:WILL RELEASE TOXIC NITROGEN OXIDE
FUMES & VAPORS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . CONTACT LOCAL HAZARDOUS OR CHEMICAL WASTE DISPOSAL
AGENCY FOR REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:832 0228, KODAK FLEXICOLOR STABILIZER & REPLENISHER LF, SOLN
Kit Part:Y
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM DODECYLBENZENE SULFONATE (CERCLA)
CAS:25155-30-0
RTECS #:DB6825000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:DIPROPYLENE GLYCOL
CAS:110-98-5
RTECS #:UB8785000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NONIONIC SURFACTANTS
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:1,2-BENZISOTHIAZOL-3(2H)-ONE
CAS:2634-33-5
RTECS #:DE4620000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 95-100%
Other REC Limits:NONE RECOMMENDED
Ingred Name:HEXAMINE
CAS:100-97-0
RTECS #:MN4725000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: EXPECTED TO BE A LOW
HAZARD FOR RECOMMENDED HANDLING. EYES: NO SPECIFIC HAZARD KNOWN.
MAY CAUSE TRANSIENT IRRITATION. SKIN-LOW HAZARD FOR RECOMMENDED
HANDLING. INGESTION-EXPECTED TO BE A LOW INGESTION HAZARD.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION-IF SYMPTOMATIC MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMA OCCUR. EYES-ANY MATERIAL THAT CONTACTS THE
EYE SHOULD BE WASHED OUT IMMEDIATELY WITH WATER. GET MEDICAL
ATTENTION IF SYMP TOMS OCCUR. SKIN-WASH WITH SOAP AND WATER. GET
MEDICAL ATTENTION IF SYMPTOMS OCCUR. INGESTION-DRINK 1-2 GLASSES OF
WATER. SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE APPROPIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER.
OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT MATERIAL,
THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN SURFACE
THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. KEEP AWAY FROM
INCOMPATIBLE SUBSTANCES.
Other Precautions:USE WITH ADEUATE VENTILATION. WASH THOROUGHLY AFTER
HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF FORMALDEHYDE IS EMITTED AT LEVELS REQUIRING
RESPIRATORY PROTECTION, THE FOLLOWING RESPIRATOR TYPE SHOULD BE
WORN: FULL FACEPIECE WITH CARTRIDGES OR CANISTERS SPECIFICALLY
APPROVED BY NIOSH FOR PROT ECTION AGAINST FORMALDEHYDE OR TYPE C.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES/HR)S
HOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:WEAR PROTECTIVE CLOTHING APPROPIATE FOR RISK
OF EXPOSURE. EYE BATH, SAFETY SHOWER, WASHING FACILITIES.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANLDING.
Supplemental Safety and Health
KEEP OUT OF REACH OF CHILDREN.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:18 MMHG
Vapor Density:0.6
Spec Gravity:1.00
pH:7.5
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID; AMBER, SLIGHT AMINE ODOR.
Percent Volatiles by Volume:95-100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE WITH COMMON MATERIALS AND CONTAMINANTS WITH WHICH THE MATERIAL MAY
REASONABLY COME INTO CONTACT.
Stability Condition to Avoid:STABLE.
Hazardous Decomposition Products:AMMONIA, FORMALDEHYDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE, OR LOCAL LAWS. FLUSH TO SEWER WITH LARGE
AMOUNTS OF WATER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LEAD/ACID STORAGE BATTERY - HYBRID
CAGE:60038
CAGE:20038
CAGE:60038
============= Composition/Information on Ingredients =============
Ingred Name:LEAD (SARA III)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: >60%
OSHA PEL:0.05 MG/M3;1910.1025
ACGIH TLV:0.15 MG/M3;DUST 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ANTIMONY (SARA III)
CAS:7440-36-0
RTECS #:CC4025000
Fraction by Wt: >2%
OSHA PEL:0.5 MG/M3
ACGIH TLV:0.5 MG SB/M3; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ARSENIC (SARA III)
CAS:7440-38-2
RTECS #:CG0525000
Fraction by Wt: <0.2%
OSHA PEL:0.5 MG/M3 (AS)
ACGIH TLV:0.01,A1 MG/M3; 9394
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CALCIUM
CAS:7440-70-2
RTECS #:EV8040000
Fraction by Wt: <0.2%
Ingred Name:SULFURIC ACID (SARA III)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 10-30%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PROPENE POLYMERS; (POLYPROPYLENE)
CAS:9003-07-4
RTECS #:UD1842000
Fraction by Wt: 5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:(ACUTE & CHRONIC) LEAD-STOMACH CRAMPS,
ANEMIA, NERVE DAMAGE. (NO DAMAGE UNDER NORMAL CONDITIONS OF USE).
SULFURIC ACID-EROSION OF TEETH; INFLAMMATION OF NOSE, THROAT AND
BRONCHIAL TUBES. WILL ALSO CAU SE BURNS, SEVERE IRRIT OF SKIN,
EYES, MOUTH, THROAT, ESOPHAGUS AND STOMACH.
Explanation of Carcinogenicity:ARSENIC: IARC, NTP GROUP 1; OSHA
REGULATED.
Effects of Overexposure:COUGHING (FROM ACID MIST), STINGING, BURNING
SENSATION ON SKIN; EYE IRRITATION.
Medical Cond Aggravated by Exposure:EXPOSURE TO SULFURIC ACID MIST MAY
CAUSE LUNG DAMAGE AND AGGRAVATE PULMONARY CONDITIONS.
======================= First Aid Measures =======================
First Aid:REMOVE FROM EXPOSURE - FLUSH ELECTROLYTE FROM SKIN WITH WATER
- FLUSH EYES FOR AT LEAST 15 MINUTES WITH WATER - SEE PHYSICIAN.
===================== Fire Fighting Measures =====================
Lower Limits:4.1%
Upper Limits:74.2%
Extinguishing Media:CARBON DIOXIDE, FOAM, HALOGEN, DRY CHEMICAL.
Fire Fighting Procedures:IF ON CHARGE, SHUT OFF POWER.
Unusual Fire/Explosion Hazard:WILL GENERATE HYDROGEN ON OVERCHARGE.
================== Accidental Release Measures ==================
Spill Release Procedures:DILUTE ACID WITH WATER, NEUTRALIZE WITH
CARBONATE. CONTAIN LARGER SPILLS WITH SAWDUST OR OTHER ABSORBENT
Neutralizing Agent:WATER, CARBONATE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM IGNITION SOURCES DURING
AND AFTER CHARGING.
Other Precautions:DO NOT SHORT TERMINALS WITH TOOLS, ETC. HANDLE WITH
CARE; AVOID CONTACT WITH SKIN AND EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SULFURIC ACID MIST-NIOSH/MSHA APPROVED 1/2 MASK
NEGATIVE PRESSURE WITH DUST AND MIST FILTER. (NOT REQUIRED UNDER
NORMAL CONDITIONS OF USE).
Ventilation:MECHANICAL (GENERAL): 3-4 AIR CHANGES/HOURS.
Other Protective Equipment:NONE (UNDER NORMAL CONDITIONS OF USE).
Work Hygienic Practices:HANDLE WITH CARE; AVOID CONTACT WITH SKIN AND
EYES.
Supplemental Safety and Health
NONE.
================== Physical/Chemical Properties ==================
HCC:B1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONTACT OF SULFURIC ACID WITH METALS MAY PRODUCE TOXIC SULFUR DIOXIDE
FUMES, HYDROGEN GAS.
Stability Condition to Avoid:PROLONGED OVERCHARGE; CONTACT OF SULFURIC
ACID WITH ORGANIC MATERIALS, COMBUSTIBLES, METALS, STRONG
OXIDIZERS.
Hazardous Decomposition Products:MAY GENERATE ARSINE, STIBINE AND/OR
SULFURIC ACID MIST ON OVERCHARGE.
==================== Disposal Considerations ====================
Waste Disposal Methods:RETURN SPENT BATTERY TO SECONDARY LEAD SMELTER.
PLACE NEUTRALIZED SPILL RESIDUE IN SEALED PLASTIC CNTNRS & DISPOSE
IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ACID RED 87,CAT NO EX0046,CI 45380
CAGE:63612
CAGE:63612
============= Composition/Information on Ingredients =============
Ingred Name:ACID RED 87 (CI 45380)
CAS:17372-87-1
RTECS #:LM5850000
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS AND SYMPTOMS OF
OVEREXPOSURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES/SKIN:CONTACT MAY CAUSE
IRRITATION.INGESTION/INHALATION:N/K .
======================= First Aid Measures =======================
First Aid:EYES:IMMEDIATELY FLUSH THOROUGHLY WITH WATER FOR AT LEAST 15
MINUTES.SKIN:WASH THOROUGHLY WITH SOAP AND WATER.INGESTION:IF
CONSCIOUS,DRINK WATER AND INDUCE VOMITING IMMEDIATELY AS DIRECTED
BY MEDICALPERSONNEL.NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.INHALATION:REMOVE TO FRESH AIR;GIVE ARTIFICIAL
RESPIRATION IF BREATHING HAS STOPPED.GET MEDICAL ASSISTANCE IN ALL
CASES OF OVEREXPOSURE.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:ANY SUITABLE FOR OTHER MATERIALS INVOLVED.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SELF-CONTAINED
BREATHING APPARATUS AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCES HIGHLY
TOXIC FUMES.HAZARDOUS DECOMPOSITION PRODUCTS:BROMINE
COMPOUNDS,OXIDES OF CARBON,SODIUM OXIDE.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE SPILL,TAKE UP WITH ABSORBENT AND
CONTAINERIZE FOR PROPER DISPOSAL.
Neutralizing Agent:EM SCIENCE SPILL-X NEUTRALIZER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED.STORE AT
CONTROLLED ROOM TEMPERATURE.DO NOT BREATH SOLUTION MIST.DO NOT GET
IN EYES,ON SKIN,OR ON CLOTHING.
Other Precautions:DO NOT TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:MATERIAL SHOULD BE HANDLED OR TRANSFERRED IN AN APPROVED
FUME HOOD OR WITH ADEQUATE VENTILATION.
Other Protective Equipment:EYE WASH AND SAFETY EQUIPMENT SHOULD BE
READILY AVAILABLE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
N/K
================== Physical/Chemical Properties ==================
HCC:N1
Decomp Temp:Decomp Text:N/K
Solubility in Water:MISCIBLE
Appearance and Odor:DARK REDDISH-ORANGE,ODORLESS LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AND REDUCING AGENTS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:BROMINE COMPOUNDS,OXIDES OF
CARBON,SODIUM OXIDE.
Conditions to Avoid Polymerization:DOES NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CAUSTIC SODA LIQUID, MEMBRANE 10%
CAGE:DO735
CAGE:DO735
CAGE:0STM5
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 48.5-91%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM HYDROXIDE (NA(OH)) (CERCLA)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 9-51.50%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3, C
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SODIUM CHLORIDE (NACL)
CAS:7647-14-5
RTECS #:VZ4725000
Fraction by Wt: 0-1.30%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CHLORIC ACID, SODIUM SALT
CAS:7775-09-9
RTECS #:FO0525000
Fraction by Wt: 0-0.30%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:EFTS OF OVEREXP: MUC MEMBS OF MOUTH, THROAT, ESOPHAGUS &
STOM. CHRONIC:NO KNOWN EFTS. FOR MORE INFO CNTCT NEHC .
RTECS #:9999999ZZ
Ingred Name:FIRST AID: IF BRTHG DFCLT HAVE TRAINED PERSON ADMIN O*2. IF
RESPIRATION STOPS, GIVE MOUTH-TO-MOUTH RESUSCITATION.(ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:GET MED ATTN. INGEST:NEVER GIVE ANYTHING BY MOUTH IF
UNCON. IF SWALLOWED, DO NOT INDUCE VOMIT. GIVE LG QTYS(ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: OF WATER. IF AVAIL, GIVE SEVERAL GLASSES OF MILK. IF
VOMIT OCCURS SPONT, KEEP AIRWAY CLEAR. GET MED ATTN IMMED.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:APPRVD CNTNRS, LABELED & STORED IN SAFE PLACE
FOR TREATMENT/DISP. SPILLS ON AREAS OTHER THAN PAVEMENT(ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: MAY BE HANDLED BY REMOVING AFFECTED SOILS & PLACING
IN APPRVD CNTNRS. PERS SHOULD WEAR ADEQ PPE & CLTHG. (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: RPT SPILLS/RELS IF REQD TO APPROP REGULATORY
AGENCIES. CAUTION:CAUSTIC SODA MAY REACT VIOLENTLY W/ACIDS & WATER.
RTECS #:9999999ZZ
Ingred Name:HNDLG/STOR PRECS: EXPOS IS POSS. WHEN HNDLG WEAR PPE. WASH
THOROUGHLY AFTER HNDLG/CNTCT - EXPOS CAN CAUSE BURNS (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: WHICH ARE NOT IMMED PAINFUL/VISIBLE. KEEP CNTNR
CLSD. PROD CAN REACT VIOLENTLY W/WATER, ACIDS & OTHER (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: SUBSTANCES - READ SPEC MIXING & HNDLG INSTRUCTIONS
BEFORE USING. PROD IS CORR TO TIN, ALUMINUM, ZINC & (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: ALLOYS CONTAINING THESE METALS & WILL REACT
VIOLENTLY W/THESE METALS IN PWDR FORM. HAZ CO GAS CAN FORM (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:ON CNTCT W/FOOD & BEVERAGE PRODS IN ENCLSD SPACES &
CAN CAUSE DEATH. FOLLOW APPROP TANK ENTRY PROCS(ANSI Z117.1).
RTECS #:9999999ZZ
Ingred Name:OTHER PRECS: SLOWLY TO SURF OF LUKEWARM WATER TO ASSURE
PROD COMPLETELY DISSOLVES AS IT IS ADDED. IF PROD ADDED (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17: TOO RAPIDLY OR W/OUT STIRRING & BECOMES
CONCENTRATED AT BOTTOM OF MIXING VESSEL, EXCESS HEAT MAY BE (ING
19)
RTECS #:9999999ZZ
Ingred Name:ING 18:GENERATED RSLTG IN DANGEROUS BOIL & SPATTER & POSS
IMMED & VIOLENT ERUPTION OF HIGHLY CAUSTIC SOLN. NEVER(ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19: ADD MORE PROD THAN CAN BE ABSORBED BY SOLN WHILE
MAINTAINING TEMP <200F (@ SEA LEVEL) TO PVNT BOIL & (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20: SPATTER. PROD CAN REACT EXPLO W/ACIDS, ALDEHYDES &
OTHER ORG CHEMS-WHEN MIXING W/SOLNS CNTNG SUCH CHEMS,(ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21: FOLLOW MIXING INSTRUCTIONS & ADD PROD VERY
GRADUALLY, STIRRING CONSTANTLY. ALWAYS EMPTY & CLEAN CNTNRS (ING
23)
RTECS #:9999999ZZ
Ingred Name:ING 22: OF ALL RESIDUES BEFORE ADDING PROD TO AVOID POSS
EXPLO RXN. SHIP RETURNABLE CNTNRS I/A/W SUPPLIER'S (ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23: RECOMS; RETURNS SHOULD COMPLY W/ALL FED, STATE &
DOT REGS. REMOVE RESIDUAL CAUSTIC SODA FROM CNTNRS BEFORE DISP.
RTECS #:9999999ZZ
Ingred Name:EYE PROT: & FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:CORR TO ALL BODY TISS BY ALL
ROUTES OF EXPOS. EFT OF LOC DERMAL EXPOS MAY CONSIST OF MULTIPLE
AREAS OF SUPERFICIAL DESTRUCTION OF SKIN/OF PRIMARY IRRITANT DERM.
SIMILARLY, INHAL OF DUST/SPRAY/MI ST MAY RSLT IN VARYING DEGREES OF
IRRIT/DMG TO RESP TRACT TISS & INCRD SUSCEPTIBILITY TO RESP
ILLNESS. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: INHAL:BRTHG DUST/MIST/SPRAY MAY CAUSE
DMG TO UPPER RESP TRACT & LUNG TISS PROPER WHICH COULD PRDCE CHEM
PNEUM, DEPENDING ON SEVERITY OF EXPOS. SKIN:CNTCT PRDCES SEV BURNS
& DESTROYS TISS. IR RIT MAY BE DELAYED. EYE CNTCT:CAUSES SEV BURNS
RSLTG IN DMG TO EYES & POSS BLINDNESS. INGEST:CAUSES SEV BURNS TO
(ING 5)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:IMMED FLUSH W/LG AMTS OF WATER FOR AT LST 15 MIN HOLDING
LIDS APART TO ENSURE FLUSHING OF ENTIRE SURF. WASHING EYES W/IN
SEVERAL SECS IS ESSNTL TO ACHIEVE MAX EFTIVENESS. GET MED ATTN
IMMED. SKIN :IMMED WASH W/PLENTY OF WATER FOR AT LST 15 MIN. REMOVE
CONTAM CLTHG & FOOTWEAR. WASH CLTHG BEFORE REUSE & DISCARD FOOTWEAR
IF CANNOT BE DECONTAM. GET MED ATTN IMMED. INHAL:REMOVE TO FRESH
AIR.(ING 6)
===================== Fire Fighting Measures =====================
Extinguishing Media:THIS PRODUCT IS NOT COMBUSTIBLE. FOAM, CARBON
DIOXIDE OR DRY CHEMICAL MAY BE USED WHERE THIS PRODUCT IS STORED.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . AVOID DIRECT CONTACT OF THIS PRODUCT WITH WATER AS THIS
CAN CAUSE A VIOLENT EXOTHERMIC REACTION.
Unusual Fire/Explosion Hazard:DIRECT CONTACT WITH WATER CAN CAUSE A
VIOLENT EXOTHERMIC REACTION. SEE REACTIVITY SECTION.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP LEAKS. CNTN & CLEAN UP SPILLS IMMED;
REMOVE BY USING VACUUM TRUCK. NEUT REMAINING TRACES OF MATL W/ANY
DILUTE INORG ACID. FLUSH SPILL AREA W/WATER FOLLOWED BY LIBERAL
COVERING OF SODIUM BICARBONA TE. REMOVE & PLACE ALL CLEAN-UP MATL
IN(ING 9)
Neutralizing Agent:INORGANIC ACID SUCH AS HYDROCHLORIC, SULFURIC,
NITRIC, PHOSPHORIC & ACETIC ACID.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT GET INTO EYES, ON SKIN/CLTHG.
AVOID BRTHG DUST/MISTS/SPRAY. DO NOT TAKE INTERNALLY. USE W/ADEQ
VENT & WEAR NIOSH APPRVD RESP PROT WHEN (ING 12)
Other Precautions:PROD CAN REACT VIOLENTLY W/WATER. CONSIDERABLE HEAT
GENERATED WHEN PROD MIXED W/WATER; WHEN MAKING SOLNS ALWAYS
CAREFULLY FOLLOW THESE STEPS. ALWAYS WEAR ALL PROT CLTHG. NEVER ADD
WATER TO PROD. ALWAY S ADD PROD-W/CONSTANT STIRRING (ING 17)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATORY PROTECTION IS NOT
REQUIRED UNDER NORMAL USE. USE NIOSH APPROVED RESPIRATORS WHERE
DUST, MIST OR SPRAY MAY BE GENERATED.
Ventilation:LOC EXHST VENT WHERE DUST/MIST/SPRAY MAY BE GENERATED.
WHERE CO/OTHER RXN PRODS MAY BE GENERATED SPEC VENT MAY BE REQD.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . WEAR
IMPERVIOUS PROT CLTHG & CHEM RESIST SFTY SHOES TO MINIMIZE CNTCT.
Work Hygienic Practices:WASH CONTAM CLTHG W/SOAP & WATER & DRY BEFORE
Supplemental Safety and Health
PH 7.5% SOLN: 14.0. MATLS TO AVOID: TO AVOID A VIOLENT EXOTHERMIC RXN.
WHEN HNDLG THIS PROD, AVOID CNTCT W/ALUMINUM, TIN, ZINC & ALLOYS
CONTAINING THESE METALS. DO NOT MIX W/STRONG ACIDS W/OUT DILUTIO N
& AGITATION TO PVNT VIOLENT OR EXPLO RXN. AVOID CNTCT W/LEATHER,
WOOL, ACIDS, ORG HALOGEN CMPDS & ORGANIC NITRO CMPDS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:230F,110C
Melt/Freeze Pt:M.P/F.P Text:14F,-10C
Vapor Pres:135 @ 60C
Spec Gravity:1.11
pH:SUPDAT
Solubility in Water:COMPLETELY SOLUBLE
Appearance and Odor:CLEAR LIQUID WITH NO DISTINCT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SEE HNDLG & STOR SECTION. AVOID CNTCT W/WATER. PROD MAY BE ADDED SLOWLY
TO WATER/ACIDS W/DILUTION & AGITATION (SUPDAT)
Stability Condition to Avoid:UNDER NORMAL CONDITIONS, THIS PRODUCT IS
STABLE.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:MATLS RSLTG FROM CLEANUP MAY BE HAZ WASTES &
THEREFORE, SUBJECT TO SPECIFIC REGS. PACKAGE, STORE, TRANSPORT &
DISP OF ALL CLEAN-UP MATLS & ANY CONTAM EQUIP I/A/W ALL APPLIC FED,
STATE & LOC HLTH & ENV IRONMENTAL REGS. CNTCT NEHC FOR MORE INFO .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TT-V-109C
CAGE:33151
CAGE:33150
CAGE:33151
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL SPIRITS
CAS:64741-41-9
Fraction by Wt: 43%
Other REC Limits:NONE SPECIFIED
ACGIH TLV:200 PPM
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:ANESTHESIA: HEADACHE, NARCOSIS,
DIZZINESS, ETC. MILD TO MODERATE IRRITATION TO EYES.
======================= First Aid Measures =======================
First Aid:REMOVE VICTIM AND RESTORE BREATHING IF NECESSARY. WASH SKIN
WITH SOAP AND WATER. FLUSH EYES WITH COLD WATER. GET MEDICAL
ATTENTION IF IT IS WARRANTED.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:105F,41C
Lower Limits:1.0
Upper Limits:6.0
Extinguishing Media:EXCLUDE AIR. USE FOAM, CO2, STEAM, WATER FOG, DRY
CHEMICALS.
Fire Fighting Procedures:DO NOT USE WATER. EXCLUDE AIR. CONSULT LOCAL
FIRE MARSHALL.
Unusual Fire/Explosion Hazard:VAPORS FORMS EXPLOSIVE MIXTURE BETWEEN
UPPER & LOWER EXPLOSION LIMITS.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID FLAME AND SPARK SOURCES. PROVIDE
ADEQUATE VENTILATION. WIPE UP SPILL WITH INERT ABSORBENT CLOTH.
RETURN TO CONTAINER IF POSSIBLE.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID OPEN FLAME AND SPARK SOURCES.
PROVIDE ADEQUATE VENTILATION. AVOID EXCESSIVE HEAT.
Other Precautions:AVOID PROLONGED OR REPEATED CONTACT WITH SKIN. DO NOT
TAKE INTERNALLY. AVOID PROLONGED OR REPEATED BREATHING OF VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ORGANIC CANNISTER MASK OR AIR PACK IF
VENTILATION IS INADEQUATE.
Ventilation:GENERAL MECHANICAL WITH EXPLOSION PROOF MOTOR AND SWITCHES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:315 TO 382F
Vapor Pres:1 @ 100F
Vapor Density:5.0
Spec Gravity:.776 @60F
Evaporation Rate & Reference:0.13 (N-BU AC=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER COLORED LIQUID, HYDROCARBON ODOR.
Percent Volatiles by Volume:49.5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NA
Hazardous Decomposition Products:CO, CO2 WHEN COMBUSTED.
==================== Disposal Considerations ====================
Waste Disposal Methods:ALL DISPOSAL PROCEDURES MUST COMPLY WITH LOCAL,
STATE AND FEDERAL REGULATIONS. INCINERATION IS SUITABLE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SET SPEED ROCK
CAGE:BLDRY
CAGE:BLDRY
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: >60%
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION:NUISANCE DUST MAY CAUSE
TEMPORARY BUT REVERSIBLE RESPIRATORY PROBLEMS. EYES:ABRASIVE ACTION
MAY CAUSE DAMAGE TO THE OUTER SURFACE OF THE EYE. SKIN CONTACT:IN
COMBINATION WITH WATER, DERMAL EXPOSURE MAY CAUSE SKIN IRRITATION.
SKIN ABSORPTION AND INGESTION:NOT APPLICABLE. CHRONIC:REPEATED
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC
MONOGRAPHS, SUPP, VOL 7, PG 341, 1987:GROUP 2A. NTP 7TH ANNUAL RPT
ON CARCINS. (SUPDAT)
Effects of Overexposure:HLTH HAZS:INHALATION OF RESPIRATORY SILICA IN
EXCESS OF THE TLV OVER EXTENDED PERIODS CAN RESULT IN IRREVERSIBLE
FIBROSIS OF THE LUNGS (SILICOSIS).
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE INDIVIDUALS TO FRESH AIR. EYES:FLUSH WITH
LARGE QUANTITIES OF WATER FOR AT LEAST 15 MINUTES; SEEK IMMEDIATE
MEDICAL ATTENTION. SKIN:WASH WITH SOAP AND WATER; GET MEDICAL
ATTENTION IF EXPOSURE IS EXTENSIVE; REMOVE CLOTHINGAND WASH BEFORE
REUSE. INGESTION:CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:THIS MATL DOES NOT GIVE FLASH POINT BY CONVENTIONAL
TEST METHS. USE EXTING AGENT SUITABLE FOR TYPE OF SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . NOT APPLICABLE.
Unusual Fire/Explosion Hazard:NOT APPLICABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:NO SPECIAL PROCEDURES ARE REQUIRED FOR
CLEAN-UP OF SPILLS OR LEAKS OF THIS MATERIAL. SWEEP UP AND RETURN
FOR REUSE OR DISCARD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM MOIST, DAMP
ENVIRONMENT.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE DUST IS EXCESSIVE USE A NIOSH APPROVED
DUST MASK.
Ventilation:VENTILATION MAY BE USED TO CONTROL OR REDUCE AIRBORNE
CONCENTRATIONS.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
VAP DENS:SAME AS WATER. EXPLAN OF CARCIN:1994:ANTICIPATED TO BE
CARCINOGEN. ANIMAL:LUNG.
================== Physical/Chemical Properties ==================
Vapor Density:SUPP DATA
Evaporation Rate & Reference:SAME AS WATER
Solubility in Water:SLIGHT
Appearance and Odor:DARK GRAY ODORLESS POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG MINERAL ACIDS, OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NOT APPLICABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS PRODUCT, WHEN DISCARDED OR DISPOSED OF, IS
NOT LISTED AS A HAZARDOUS WASTE IN FEDERAL REGULATIONS. DISPOSE IN
A LANDFILL IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS & STEEL OVERALL COMPOSITION
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:B&B 786 P-2
CAGE:21361
CAGE:21361
============= Composition/Information on Ingredients =============
Ingred Name:DIETHYLENE GLYCOL MONOETHYL ETHER
CAS:111-90-0
RTECS #:KK8750000
Other REC Limits:NONE SPECIFIED
Ingred Name:OTHER COMPONENTS (TYPE NOT SPECIFIED)
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATION OF
EYES,SKIN,RESPIRATORY OR G.I.TRACTS.
Explanation of Carcinogenicity:DATA PER MSDS
Effects of Overexposure:SEE HEALTH HAZARDS DATA.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
FOR 15 MINUTES HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION.
SKIN:REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER. IF
IRRITATION PERSISTS, GET MEDICAL ADVICE. INGESTION:DO NOT INDUCE
VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET IMMEDIATE
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:180F,82C
Extinguishing Media:N/K WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;CONTAIN FREE
MATERIAL IF POSSIBLE;USE SUITABLE INERT ABSORBENT MATERIAL AND
RECOVER FOR PROPER DISPOSAL IN AN APPROVED CONTAINER.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT
CONTAINERS FROM PHYSICAL DAMAGE.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE MIST. AVOID
PROLONGED OR REPEATED BREATHING OF VAPOR. AVOID CONTACT WITH EYES.
USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR AS REQUIRED
IF ABOVE PEL/TLV OR SCBA IN AN ENCLOSED AREA.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER,WORK
CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS.
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:200F,93C
Spec Gravity:1.03
Evaporation Rate & Reference:<1.0 ETHER=1
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID-MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
OTHER UNIDENTIFIED COMPONENTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES.DISPOSAL MUST BE MADE
IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:2406 SALMON DECORATOR PAINTS
Resp. Party Other MSDS Num.:DEC/KR-5
CAGE:TO019
CAGE:TO019
============= Composition/Information on Ingredients =============
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
= Wt:14.
OSHA PEL:1800 MG/M3;1000 PPM
Ingred Name:BUTANE
CAS:106-97-8
RTECS #:EJ4200000
= Wt:6.
OSHA PEL:800 PPM
ACGIH TLV:1900 MG/M3;800 PPM
Ingred Name:ETHYLBENZENE
CAS:100-41-4
RTECS #:DA0700000
= Wt:2.
OSHA PEL:435 MG/M3;100 PPM
OSHA STEL:125 PPM
ACGIH TLV:434 MG/M3;100 PPM
ACGIH STEL:543 MG/M3;125 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE
CAS:1330-20-7
RTECS #:ZE2100000
= Wt:9.
OSHA PEL:100 PPM
OSHA STEL:150 PPM
ACGIH TLV:434 MG/M3;100 PPM
ACGIH STEL:651 MG/M3;150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:1-BUTANOL
CAS:71-36-3
RTECS #:EO1400000
= Wt:1.
OSHA PEL:300 MG/M3;100 PPM
OSHA STEL:50 PPM (SKIN)
ACGIH STEL:C152 MG/M3;C50 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETONE
CAS:67-64-1
RTECS #:AL3150000
= Wt:38.
OSHA PEL:2400 MG/M3;1000 PPM
OSHA STEL:750 PPM
ACGIH TLV:1780 MG/M3;750 PPM
ACGIH STEL:2380 MG/M3;1000 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE
CAS:78-93-3
RTECS #:EL6475000
= Wt:4.
OSHA PEL:590 MG/M3;200 PPM
OSHA STEL:300 PPM
ACGIH TLV:590 MG/M3;200 PPM
ACGIH STEL:885 MG/M3;300 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ISOBUTYL KETONE
CAS:108-10-1
RTECS #:SA9275000
= Wt:6.
OSHA PEL:50 PPM
OSHA STEL:75 PPM
ACGIH TLV:205 MG/M3;50 PPM
ACGIH STEL:307 MG/M3;75 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:1-METHOXY-2-PROPANOL ACETATE
CAS:108-65-6
RTECS #:AI8925000
= Wt:6.
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
= Wt:6.
OSHA PEL:10 [5] MG/M3
ACGIH TLV:10 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF EYES, SKIN AND
RESPIRATORY SYSTEM. MAY CAUSE NERVOUS SYSTEM DEPRESSION. EXTREME
OVEREXPOSURE MAY RESULT IN UNCONSCIOUSNESS AND POSSIBLY DEATH.
CHRONIC: PROLONGED OVEREXPOSURE TO SOLVENTINGREDIENTS MAY CAUSE
ADVERSE EFFECTS TO LIVER, URINARY, BLOOD-FORMING, CARDIOVASCULAR &
REPRODUCTIVE SYSTEMS. METHYL ETHYL KRTONE MAY INCREASE THE NERVOUS
SYSTEM EFFECTS OF OTHER SOLVENTS. METHYL ETH YL KETONE MAY INCREASE
THE NERVOUS SYSTEM EFFECTS OF OTHER SOLVENTS. REPORTS HAVE
ASSOCIATED REPEATED OR PROLONGED OVEREXPOSURE TO SOLVENTS WITH
PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:NO INGREDIENT IN THESE PRODUCTS IS AN
IARC, NTP OR OSHA LISTED CARCINOGEN.
Effects of Overexposure:HEADACHE, DIZZINESS, NAUSEA, AND LOSS OF
COORDINATION ARE INDICATIONS OF EXCESSIVE EXPOSURE TO VAPORS OR
SPRAY MISTS. TENDERNESS AND ITCHING OR BURNING SENSATION MAY
INDICATE EYE OR EXCESSIVE SKIN EXP OSURE.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:IF INHALED: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE
BREATHING. KEEP WARM AND QUIET. IF ON SKIN: WASH AFFECTED AREA
THOROUGHLY WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING AND
LAUNDER BEFORE RE USE. IF IN EYES: FLUSH WITH LARGE AMOUNTS OF
WATER FOR 15 MINUTES. GET MEDICAL ATTENTION. IF SWALLOWED: NEVER
GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. DO NOT INDUCE
VOMITING. GIVE CONSCIOUS P ATIENT SEVERAL GLASSES OF WATER. SEEK
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:=-17.6C, 0.F
Lower Limits:1.0
Upper Limits:13.1
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT INCLUDING
SELF-CONTAINED BREATHING APPARATUS SHOULD BE USED. WATER SPRAY MAY
BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE PREFERABLE. WATER
MAY BE USED TO COOL CLOSED CO NTAINERS TO PREVENT PRESSURE BUILD-UP
AND POSSIBLE AUTOIGNITION OR EXPLOSION WHEN EXPOSED TO EXTREME
HEAT.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO
BUILD-UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT. ISOLATE FROM
HEAT, ELECTRICAL EQUIPMENT, SPARKS & OPEN FLAME. APPLICATION TO HOT
SURFACES REQUIRES SPECIAL PRE CAUTIONS. DURING EMERGENCY CONDITIONS
OVEREXPOSURE TO DECOMPOSITION PRODUCTS MAY CAUSE A HEALTH HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & OPEN
FLAME. VAPORS WILL ACCUMULATE READILY & MAY IGNITE EXPLOSIVELY.
DURING USE & UNTIL ALL VAPORS ARE GONE. KEEP AREA VENTILATED-DO NOT
SMOKE-EXTINGUISH ALL FLAMES, PILO T LIGHTS & HEATERS -TURN OFF
STOVES, ELECTRIC TOOLS & APPLIANCES, ANY OTHER SOURCES OF IGNITION.
Other Precautions:CONSULT NFPA CODE. USE APPROVED BONDING & GROUNDING
PROCEDURES. CONTENTS UNDER PRESSURE. DO NOT PUNCTURE, INCINERATE,
OR EXPOSE TO TEMPERATURE ABOVE 120F. HEAT FROM SUNLIGHT, RADIATORS,
STOVES, HOT WA TER, & OTHER HEAT SOURCES COULD CAUSE CONTAINERS TO
BURST. DO NOT TAKE INTERNALLY. KEEP OUT OF THE R EACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, WEAR A PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESPIRATOR APPROVED BY NIOSH/MSHA FOR PROTECTION
AGAINST INGREDIENTS. WHEN SANDING OR ABRADING THE DRIED FILM, WEAR
A DUST/MIST RESPIRATOR APPROVED BY NIOSH/MSHA FOR DUST WHICH MAY BE
GENERATED FROM THIS PRODUCT.
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF THE
EXPOSURE TO MATERIALS IN SECTION II IS MAINTAINED BELOW
APPLICABLE EXPOSURE LIMITS.
PRODUCTS .
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE
REUSE
Supplemental Safety and Health
INTENTIONAL MISUSE OF DELIBERATELY CONCENTRATING AND INHALING THE
CONTENTS CAN BE HARMFUL OR FATAL.
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:<0-302F
Vapor Density:>AIR
VOC Grams/Liter:3.14
Evaporation Rate & Reference:FATSER THAN ETHER
Appearance and Odor:COLOR: SALMON.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF METALS IN INGREDIENTS.
=================== Toxicological Information===================
Toxicological Information:RATS EXPOSED TO TITANIUM DIOXIDE DUST AT 250
MG/M3 DEVELOPED LUNG CANCER, HOWEVER, SUCH PRESSURE ELEVELS ARE NOT
ATTAINABLE IN THE WORKPLACE. WEIGHT PER GALLONS (LBS.): 6.56. VOC
AS A PERCENT BY WEIGH T PER BAAQMD & CARB: 47.6. VAPOR PRESSURE:
PROPANE-760 MMHG, BUTANE-760 MMHG, ETHYLBENZENE-7.1 MMHG,
XYLENE-5.9 MMHG, 1-BUTANOL-5.5 MMHG, ACETONE-180 MMHG, METHYL ETHYL
KETONE-70 MMHG, METHYL ISOBUTYL KETONE-16 MMHG,
1-METHOXY-2-PROPANOL ACETATE-1.8 MMHG.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE. DEPRESSURIZE CONTAINER.
DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE, AND LOCAL REGULATIONS
REGARDING POLLUTION.
===================== Regulatory Information =====================
SARA Title III Information:ETHYL BENZENE, XYLENE, 1-BUTANOL, METHYL
ETHYL KETONE, METHYL ISOBUTYL KETONE: INGREDIENTS SUBJECT TO THE
REPORTING REQUIREMENTS OF THE SUPERFUND AMENDMENTS AND
REAUTHORIZATION ACT (SARA) SECTION 313, 40 CFR 372.65 C.
Federal Regulatory Information:TSCA CERTIFICATION: ALL CHEMICALS IN
THESE PRODUCTS ARE LISTED, OR ARE EXEMPT FROM LISTING, ON THE TSCA
INVENTORY.
State Regulatory Information:WARNING: THESE PRODUCTS CONTAIN A
CHEMICAL/S KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER AND
BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
======================= Other Information =======================
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:HYDROCORTONE ACETATE (SUSPENSION)
Preparer's Name:E SARGENT
CAGE:GO622
CAGE:GO622
CAGE:06990
============= Composition/Information on Ingredients =============
Ingred Name:HYDROCORTISONE ACETATE
CAS:50-03-3
RTECS #:GM8960000
Fraction by Wt: 25-50%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(MOUSE): 6 GM/KG
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED THERAPEUTIC USE MAY RESULT
IN SUPPRESSION OF PITUITARY-ADRENAL FUNCTION. CORTICOIDS MAY MASK
SIGNS OF INFECTION. PROLONGED USE MAY CAUSE POSTERIOR SUBCAPSULAR
CATARACTS, GLAUCOMA, OCULAR INF ECTIONS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INFECTION, FOLLOWING PROLONGED THERAPY: FEVER,
MYALGIA, ARTHRALGIA & MALAISE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER. SKIN: WASH W SOAP & WATER. INGESTION:
TREATMENT DEPENDS ON THE AMOUNT OF PRODUCT INGESTED. NO SPECIFIC
ANTIDOTE; TREATMENT IS SUPPORTIVE & SYMPTOMATIC. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP UNNECESSARY PERSONS AWAY. ABSORB SMALL
LEAKS ON VERMICULITE/OTHER SUITABLE ABSORBING MATERIAL & PLACE IN A
SEALED CONTAINER FOR DISPOSAL. DIKE LARGE LEAKS & TRANSFER TO AN
APPROPRIATE CONTAINER F OR DISPOSAL. USE PROTECTIVE EQUIPMENT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN WELL CLOSED CONTAINER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED
Ventilation:NONE REQUIRED
Other Protective Equipment:WORK UNIFORM
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
pH:5-7
Solubility in Water:1 MG/100ML
Appearance and Odor:WHITE, MOBILE SUSPENSION
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, AUTOCLAVING, FREEZING
==================== Disposal Considerations ====================
Waste Disposal Methods:AVOID CONTACT OF MATERIALS & RUNOFF W/SOIL &
SURFACE WATERWAYS. DISPOSE OF/TREAT RESIDUES/CONTAMINATED SOILS IN
ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PHOTOENGRAVING GLUE
CAGE:55636
CAGE:55636
============= Composition/Information on Ingredients =============
Ingred Name:PHENOL (SARA III)(SARA III)
CAS:108-95-2
RTECS #:SJ3327000
Fraction by Wt: 0.9%
OSHA PEL:5 PPM, S
ACGIH TLV:5 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:P.E. GLUE A NONHAZARDOUS MATERIAL IS
PROTECTED AGAINST BACTERIA GROWTH WITH O.9% PHENOL. PHENOL IS
POISONOUS & SHOULD NOT BE INGESTED. ANIMAL TESTS USING INGESTION
SHOW IT AS A SUSPECT MUTAGEN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:INGESTION OF PHENOL CAUSES INTENSE BURNING OF
MOUTH AND THROAT FOLLOWED BY ABDOMINAL PAIN AND DISTRESS. LETHAL
ORAL DOSES FOR ADULTS HAVE RANGED FROM 1 TO 10 GMS AND 50 TO 500 MG
FOR INFANTS.
Medical Cond Aggravated by Exposure:DERMATITIS.
======================= First Aid Measures =======================
First Aid:SKIN: WASH OFF WITH SOAP AND WATER, REMOVE CONTAMINATED
CLOTHING. EYES: WASH WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. INGEST: INDUCE VOMITING. INHAL: REMOVE TO FRESH AIR.
SUPPORT BREATHI NG (GIVE O*2/ARTIFICIAL RESPIRATION) CALL MD .
===================== Fire Fighting Measures =====================
Extinguishing Media:NOT APPLICABLE. USE MEDIA SUITABLE FOR SURROUNDING
FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH WITH WATER FOR SMALL SPILLS. FOR LARGE
SPILLS COLLECT LIQUID WITH ABSORBENT MATERIAL AND PACKAGE FOR
DISPOSAL ACCORDING TO LOCAL, STATE AND FEDERAL REGULATIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE OR BELOW FOR
MAXIMUM SHELF LIFE.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE. NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Other Protective Equipment:NONE
Work Hygienic Practices:FOLLOW NORMAL SAFE WORK PRACTICES WHEN DEALING
WITH CHEMICALS.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:T3
Boiling Pt:B.P. Text:214F,101C
Melt/Freeze Pt:M.P/F.P Text:>41F,>5C
Spec Gravity:1.17 (H*2O=1)
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:TRANSPARENT TAN; SAFROL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:MATERIAL IS BIODEGRADABLE. DISPOSE IN SANITARY
SEWER OR APPROPRIATE LANDFILL. DISPOSE OF I/A/W FEDERAL, STATE AND
LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:040093901 PYRIDOXAL-5-PHOSPHATE TABLETS
Preparer's Name:MICHAEL A FAZIO
CAGE:32239
CAGE:32239
============= Composition/Information on Ingredients =============
Ingred Name:PYRIDOXAL 5, PHOSPHATE
CAS:54-47-7
RTECS #:UV1207000
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LARGE VOLUMES OF WATER FOR 15 MINS. SKIN: FLUSH
AREAS W/LARGE VOLUMES OF WATER FOR 15 MINS. INGESTION: KEEP WARM &
QUIET. INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN/CPR IF NEEDED.
OBTA IN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:>392F
Extinguishing Media:USE MEDIA SPECIFIC FOR SITE CONDITIONS.
Fire Fighting Procedures:WEAR SCBA & PROTECTIVE GARMENTS, IF POSSIBLE
HAVE THIS PRODUCT REMOVED FROM SCENE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. IF DRY, MOP UP, PLACE IN A
SUITABLE CONTAINER, SEAL, LABEL & HOLD FOR DISPOSAL. SOLUTION: USE
AN ABSORBENT MATERIAL TO CONTAIN/PICKUP. ONCE SPENT, PLACE
CONTAMINATED DISPOSABLE INTO A SUITABLE CONTAINER/SEAL/LABEL &
HOLD FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT 35.6-46.4F. GOOD LABORATORY
TECHNIQUE SHOULD BE USED WHEN HANDLING PRODUCT.
Other Precautions:AVOID CONTACT W/SKIN/EYES. DON'T EAT, DRINK/SMOKE
WHILE WORKING W/REAGENTS. DON'T MOUTH PIPETTE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NON REQUIRED IF VENTILATION IS ADEQUATE.
Ventilation:ADEQUATE GENERAL EXHAUST.
Other Protective Equipment:EYE WASH STATIONS, DELUGE SHOWERS, LAB COAT.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
SPILLS: UPON COMPLETION, OBSERVE APPROPRIATE CHEMICAL HYGIENE. CLEAN
UP, WASH SITE W/WATER.
================== Physical/Chemical Properties ==================
Solubility in Water:COMPLETE (REAGENT)
Appearance and Odor:TABLETS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:EXCESS HEAT, FLAME, PRESSURE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ETC. 1742 BULK
Preparer's Name:B RIFFEL
CAGE:DO989
CAGE:DO989
CAGE:54700
============= Composition/Information on Ingredients =============
Ingred Name:DEIONIZED WATER
Fraction by Wt: 85-92%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ISOPROPYL ALCOHOL; (ISOPROPANOL) (SARA 313)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 7.5%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
Ingred Name:FRAGRANCE
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:AMPHOTERIC SURFACTANT
CAS:68296-20-4
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUND:7.4% CALCULATED FROM FORMULA
WEIGHT.
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION:LITTLE, IF ANY, EFFECTS
CAUSED BY INHALATION OF THE VAPORS FROM THIS PRODUCT. EYES:MODERATE
TO SEVERE IRRITANT. SKIN:PRODUCT IS MILD SKIN IRRITANT. DEFATTING
POSSIBLE WITH USE. INGESTION:NA USEA AND DIARRHEA POSSIBLE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. IF BRTHG HAS STOPPED, ADMIN ARTF
RESP. SEEK MED ATTN. EYES:FLUSH FOR @ LST 15 MIN W/CLEAR WATER. IF
IRRIT PERSISTS, SEEK MED ATTN. SKIN:WASH W/SOAP & WATER.
INGEST:INDUCE VO MIT W/2 GLASSES OF TEPID SALT WATER & FINGER DOWN
THROAT. SEEK MED ATTN. NOTE:ADRENALIN & OTHER SIMILAR CARDIAC
STIMULANTS SHOULD NOT BE USED TO TREAT EFTS OF OVEREXP TO THIS
PROD. SEE INGS.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Extinguishing Media:WATER, FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB ON APPROPRIATE MATERIAL. PLACE IN
SEALED CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP THIS AND ALL CHEMICALS OUT OF
REACH OF CHILDREN. THIS PRODUCT IS FOR INDUSTRIAL USE ONLY.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NONE NEEDED.
Ventilation:NORMAL, AMBIENT ATMOSPHERE ACCEPTABLE.
Other Protective Equipment:NONE SPECIFIED BY MFR.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:0.978
pH:7
Solubility in Water:100
Appearance and Odor:CLEAR WATER-WHITE LIQUID WITH PLEASANT ODOR.
Percent Volatiles by Volume:98
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTIVE ALKALI METALS, STRONG ACIDS AND BASES.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:FORCED COMBUSTION YIELDS CARBON
OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:MATERIAL MAY BE DISPOSED OF BY A LICENSED
RECLAIMER OR INCINERATION FACILITY. CONSULT LOCAL, STATE AND
FEDERAL DISPOSAL AUTHORITIES FOR APPROVED PROCEDURES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SHER-LINER STRIPING PAINT, 160-0022, HANDICAP BLUE
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:PROPANE (PROPELLANT). VP:760.
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 10%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT
Ingred Name:BUTANE (PROPELLANT). VP:760.
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: 10%
OSHA PEL:800 PPM
ACGIH TLV:800 PPM
Ingred Name:V.M. & P. NAPHTHA. VP:12.
CAS:64742-89-8
Fraction by Wt: 3%
OSHA PEL:300 PPM;400 PPM(MFR)
ACGIH TLV:300 PPM (MFR)
Ingred Name:BENZENE, ETHYL-; (ETHYLBENZENE) (SARA 313). VP:7.1.
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 2%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM;125 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE (SARA 313) (CERCLA). VP:5.9.
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 13%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM;150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE (SARA 313) (CERCLA). VP:180.
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 17%
OSHA PEL:1000 PPM
ACGIH TLV:750 PPM;1000 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CARBONIC ACID, CALCIUM SALT (1:1); (CALCIUM CARBONATE).
OSHA PEL:15 MG/M3; 5 MG/M3 RDUST (MFR).
CAS:471-34-1
RTECS #:FF9335000
Fraction by Wt: 5%
OSHA PEL:SEE INGREDIENT
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:BARIUM SULFATE
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: 7%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 11%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:BARIUM COMPOUND (CONTAINING 4% BARIUM)
Fraction by Wt: 7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:WORKPLACE. RPTS HAVE ASSOC RPTD & PRLNG OVEREXP TO
SOLVS W/PERM BRAIN & NERV SYS DMG. INTENTIONAL MISUSE (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:BY DELIB CONC & INHAL CONTENTS CAN BE HARMFUL/FATAL.
WARNING:PROD CONTAINS CHEM(S) KNOWN TO THE STATE OF (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:CALIFORNIA TO CAUSE CANCER (CAL PROP 65).
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:PROCS. HEAT FROM SUNLIGHT, RADIATORS, STOVES,
HOT WATER & OTHER HEAT SOURCES COULD CAUSE CNTNR TO (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:BURST. DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF
CHILDREN. USE ONLY W/ADEQ VENT. AVOID BRTHG VAP & (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:SPRAY MIST. AVOID CONT W/SKIN & EYES. THESE COATINGS
MAY CNTN MATLS CLASSIFIED AS NUISANCE PARTICULATES (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:WHICH MAY BE PRESENT AT HAZ LEVELS ONLY DURING
SANDING/ABRADING OF DRIED FILM. IF NO SPECIFIC DUSTS ARE (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:LISTED, APPLIC LIMS FOR NUISANCE DUSTS ARE ACGIH TLV
10 MG/M3 (TDUST), OSHA PEL 15 MG/M3 (TDUST), 5 MG/M3(ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19:(RESPIRABLE FRACTION). ADDITION OF REDUCERS/OTHER
ADDITIVES TO THESE PRODS MAY SUBSTANTIALLY ALTER THE (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20:COMPOSITION & HAZARDS OF THE PRODUCTS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPOS MAY BE BY INHAL &/OR SKIN/EYE
CONT, DEPENDING ON CNDTNS OF USE. TO MIN EXPOS, FOLLOW RECS FOR
PROPER USE, VENT & PPE. ACUTE:IRRIT OF EYES, SKIN & RESP SYS. MAY
CAUSE NERV SYS DEPRESS. EXTREME OV EREXP MAY RSLT IN UNCON & POSS
DEATH. HDCH, DIZZ, NAUS & LOSS OF COORD ARE INDICATIONS OF
EXCESSIVE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:EXPOS TO VAPS/SPRAY MIST. REDNESS &
ITCH/BURNING SENSATION MAY INDICATE EYE/EXCESSIVE SKIN EXPOS.
CHRONIC:PRLNG OVEREXP TO SOLV INGS MAY CAUSE ADVERSE EFTS TO LIVER,
URINARY, REPRO & CARDIO-V ASCULAR SYS. RATS EXPOS TO TITANIUM
DIOXIDE DUST AT 250 MG/M3 DEVEL LUNG CANCER, HOWEVER, SUCH EXPOS
LEVELS ARE (SUPDAT)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM &
QUIET. SKIN:WASH AFFECTED AREA THOROUGHLY W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING & LAUNDER BEFORE RE-USE. EYES:FLUSH W/LARGE
AMOUNTS OFWATER FOR AT LEAST 15 MINUTES. GET MEDICAL ATTENTION.
INGEST:SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:<0F,<-18C
Lower Limits:0.7%
Upper Limits:12.8%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL FOAM.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER SPRAY MAY BE INEFT. IF WATER IS USED, FOG NOZZ ARE PREF.
WASTE MAY BE USED TO COOL CLSD CNTNRS TO (SUPDAT)
Unusual Fire/Explosion Hazard:EXTREMELY FLAMM. CLSD CNTNRS MAY EXPLODE
WHEN EXPOS TO EXTREME HEAT. APPLICATION TO HOT SURFS REQS SPECIAL
PRECS. DURING EMER CNDTNS OVEREXP TO DECOMP (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE &
REMOVE W/INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DOL STOR CATEGORY-1A. CONTENTS ARE
EXTREMELY FLAMM. KEEP AWAY FROM HEAT, SPKS & OPEN FLAME. VAPS WILL
ACCUM READILY & MAY IGNITE EXPLOSIVELY.
Other Precautions:DURING USE & UNTIL ALL VAPS ARE GONE:KEEP AREA
VENTED; DO NOT SMOKE; EXTING ALL FLAMES, PILOT LIGHTS & HEATERS;
TURN OFF STOVES, ELEC TOOLS & APPLIANCES & ANY OTHER SOURCES OF
IGNIT. CONSULT NFPA CODE . USE APPRVD BONDING & GROUNDING(ING 15)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIMS BY VENT, WEAR A PROPERLY FITTED NIOSH APPRVD ORG
VAP/PARTICULATE RESP FOR PROT AGAINST INGS. WHEN SANDING/ABRADING
DRIED FILM, WEAR NIOSH APPRV D DUST/MIST RESP FOR DUST WHICH
(SUPDAT)
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPT IF EXPOS TO INGS IS
MAINTAINED BELOW APPLIC EXPOS LIMS. REFER TO OSHA STDS (SUPP DATA)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC:PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN EXPOS
TO EXTREME HEAT. EXPLO HAZ:PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT
BE IMMED APPARENT. OBTAIN MED ATTN. RESP PROT:MAY BE GENERATED
FROM THIS PROD, UNDERLYING PAINT/ABRASIVE. VENT:1910.94, 1910.107,
1910.108. EFTS OF OVEREXP:NOT ATTAINABLE IN (ING 12)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:<325F,<163C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Volatile Org Content %:56
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:>75
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF METALS IN INGREDIENTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THESE PRODUCTS MAY BE HAZARDOUS AS
DEFINED UNDER THE RCRA (40 CFR 261). WASTE MUST BE TESTED FOR
IGNITABILITY TO DETERM APPLIC EPA HAZ WASTE NUMBER. DO NOT INCIN.
DEPRESSURIZE CNTNR. DISP O F I/A/W FED, STATE & LOC REGS
REGARDINGPOLLUTION.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BRAKE-KLEEN, 9929
CAGE:0BPN7
CAGE:0BPN7
============= Composition/Information on Ingredients =============
Ingred Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM/30000STEL
Ingred Name:ETHYLENE, TETRACHLORIDE; (TETRACHLOROETHYLENE) (SARA 313)
(CERCLA)
CAS:127-18-4
RTECS #:KX3850000
OSHA PEL:100 PPM, Z-2
ACGIH TLV:25PPM/100STEL,A3
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION:DIZZINESS, PROLONGED
EXPOSURE MAY LEAD TO UNCONSCIOUSNESS. EYES:STRONG IRRITATION.
SKIN:MAY CAUSE DEFATTING AND DRYING.
Explanation of Carcinogenicity:TETRACHLOROETHYLENE:IARC MONOGRAPHS,
SUPP, VOL 7, PG 355, 1987:GROUP 2B. NTP 7TH ANNUAL RPT ON CARCINS,
1994:(SUP DAT)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:EXCESSIVE EXPOSURE WILL AGGRAVATE
RESPIRATORY, CARDIOVASCULAR OR PULMONARY ILLNESSES.
======================= First Aid Measures =======================
First Aid:INGESTION:CALL MD IMMEDIATELY . INHALATION:REMOVE TO FRESH
AIR. EYES:FLUSH WITH RUNNING WATER FOR AT LEAST 15 MINUTES.
SKIN:WASH WITH SOAP AND WATER. IF IRRITATION PERSISTS CONTACT
PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:CO*2.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CONTENTS UNDER PRESSURE. EXPOSURE TO
TEMPERATURES ABOVE 120F MAY CAUSE BURSTING.
================== Accidental Release Measures ==================
Spill Release Procedures:MOP UP WITH RAG OR USE SOME ABSORBENT CLAY
MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT USE OR STORE NEAR HEAT OR OPEN
FLAMES. EXPOSURE TO TEMPERATURES ABOVE 120F MAY CAUSE BURSTING.
Other Precautions:NOT APPLICABLE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NONE.
Ventilation:LOCAL EXHAUST:YES.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER . LONG SLEEVES AND LONG PANTS.
Work Hygienic Practices:DO NOT SMOKE WHILE USING. WASH HANDS AFTER USE.
Supplemental Safety and Health
EXPLAN OF CARCIN:ANTICIPATED TO BE CARCINOGEN. ANIMAL:LIVER TUMORS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:250F,121C
Vapor Pres:13
Vapor Density:>1
Spec Gravity:1.0 (H*2O=1)
Evaporation Rate & Reference:2.1 (BUTYL ACETATE=1)
Solubility in Water:0%
Appearance and Odor:CLEAR SPRAY, STRONG CHLORINATED SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SOME PLASTICS.
Stability Condition to Avoid:TEMPERATURES ABOVE 120F.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF RESIDUE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL GUIDELINES. DO NOT PUNCTURE OR INCINERATE
CONTAINER. DO NOT REUSE CONTAINER. WRAP AND PLACE IN TRASH
COLLECTION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:815 9840 PRE-BLEACH & REPLENISHER; PROCESS
CAGE:19139
CAGE:19139
CAGE:5K871
CAGE:61125
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 60-65%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM SULFITE
CAS:10117-38-1
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHYLENEDIAMINE-TETRAACETIC ACID (EDTA) (SARA III)
CAS:60-00-4
RTECS #:AH4025000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:1-THIOGLYCEROL
CAS:96-27-5
RTECS #:TY8140000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:STABILIZER
Fraction by Wt: 20-25%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT MAY PRODUCE TRANSIENT
IRRITATION OF THE EYES AND/OR ANALLERGIC SKIN REACTION. FOR
RECOMMENDED USE AND HANDLING IT IS EXPECTED TO BE LOW INGESTION OR
INHALATION HAZARD.
Explanation of Carcinogenicity:WHILE NOT AN INGREDIENT,FORMALDEHYDE MAY
BE LIBERATED UNDER THERMAL DEGRADATION. SEE REPORTS FOR DETAILS OF
FORMALDEHYDE
Effects of Overexposure:INHALED:INHALATION OF FUMES OF CHEMICAL OR
THERMAL DEGRADATION MAY PRODUCE IRRITATION. EYE:TRANSIENT
IRRITATION. SKIN:MAY CAUSE ALLERGIC REACTION. INGESTION:LOW
INGESTION HAZARD.
Medical Cond Aggravated by Exposure:NO INFORMATION GIVEN ON MSDS BY
MFR.
======================= First Aid Measures =======================
First Aid:INHALED:IF SYMPTOMATIC,REMOVE TO FRESH AIR. EYE:FLUSH
IMMEDIATELY WITH WATER. SKIN:FLUSH SKIN WITH WATER & WASH WITH SOAP
& WATER. REMOVE CONTAMINATED CLOTHING & SHOES, LAUNDER/CLEAN BEFORE
REUSE. ING ESTED:DRINK 1-2 GLASSES OF WATER AND GET IMMEDIATED
MEDICAL ATTENTION.*IF ANY SYMPTOMS PERSIST OR ARE SEVERE, GET
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE AGENT APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL:FLUSH MATERIAL TO THE SEWER WITH LARGE
AMOUNTS OF WATER. LARGE:ABSORB WITH INERT MATERIAL AND PLACE IN
CHEMICAL WASTE CONTAINER. PREVENT RUNOFF FROM ENTERING DRAINS,
SEWERS, AND STREAMS. FLUSHRESIDUAL SPILL AND AREA WITH WATER.
Neutralizing Agent:NO INFORMATION GIVEN ON MSDS BY MFR.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED AND AWAY
FROM STRONG ACIDS AND STRONG BASES.
Other Precautions:EXPECTED TO HAVE MODERATE BOD. EXPECTED TO HAVE LOW
POTENTIAL TO AFFECT AQUATIC ORGANISMS AND WASTE TREATMENT
MICROORGANISMS. A FINAL CONCENTRATION IS NOT EXPECTED TO CAUSE AN
ADVERSE ENVIRONMENTAL EF FECT AFTER TREATMENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATORY PROTECTION MAY BE NEEDED IN SPECIAL
CIRCUMSTANCES.
Ventilation:GOOD VENTILATION ( 10 ROOM VOL PER HOUR IS CONSIDERED GOOD
GENERAL VENTILATION). SUPPLEMENTAL VENTILATION MAY BE NEEDED.
Other Protective Equipment:IMPERVIOUS CLOTHING
Work Hygienic Practices:MFR: ?HMIS:USE GOOD CHEMICAL HYGIENE
PRACTICE. AVOID UNNECESSARY CONTACT. WASH THOROUGHLY BEFORE EATING
OR DRINKING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NONE
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:18 MM
Vapor Density:0.6
Spec Gravity:1.23
pH:5.9
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR ODORLESS SOLUTION
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, STRONG BASES
Stability Condition to Avoid:SUPPLIER DID NOT ADDRESS THIS FIELD.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY PRODUCE
OXIDES OF SULFUR
Conditions to Avoid Polymerization:WILL NOT OCCUR
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTRACT WITH LICENSED CHEMICAL DISPOSAL
COMPANY. DISCHARGE, TRDEATMENT, OR DISPOSAL MAY BE SUBJECT TO
FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SUPER HEATCRETE 33
CAGE:MTSAV
CAGE:4K322
CAGE:MTSAV
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM OXIDE (2:3); (ALUMINA) (SARA 313)
CAS:1344-28-1
RTECS #:BD1200000
Fraction by Wt: 94%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (SILICON OXIDE)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 0.09%
OSHA PEL:10 MG/M3 (MFR)
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:IRON (III) OXIDE; (IRON)
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 0.31%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3 FUME (FE)
Ingred Name:CALCIUM OXIDE; (LIME)
CAS:1305-78-8
RTECS #:EW3100000
Fraction by Wt: 5.7%
OSHA PEL:5 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:TITANIA; (TRACE MINERALS)
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:DRY SKIN, SKIN IRRITATION, SKIN
BURNS & ALLERGIC DERMATITIS IN HYPERSENSITIVE INDIVIDUALS. EYE
IRRITATION, EYE ABRASION WHEN RUBBED. IRRITATION OR INFLAMMATION TO
LININGS OF UPPER RESPIRATORY TR ACT. PHYSICAL INJURY DUE TO STEAM
SPALLING. CHRONIC:EXPOSURE OVER A PERIOD OF YEARS MAY LEAD TO
SILICOSIS (LUNG INJURY).
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . EYES:IMMEDIATELY FLUSH
W/POTABLE WATER FOR A MINIMUM OF 15 MINUTES, SEEK ASSISTANCE FROM
MD. SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD .
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE - NON FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CARE SHOULD BE EXERCISED TO PREVENT
GENERATION OF DUST DURING HANDLING, USE & CLEAN-UP TO AVOID SKIN &
EYE CONTACT & BREATHING OF DUST.
Other Precautions:PROPER REFRACTORY PRACTICES MUST BE FOLLOWED FOR
CURING & FIRING TO SERVICE TEMPERATURES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:APPROPRIATE CONTROL MEASURES INCLUDE THE USE OF
NIOSH/MSHA APPROVED RESPIRATORS.
Ventilation:APPROPRIATE CONTROL MEASURES INCLUDE THE USE OF ADEQUATE
VENTILATION TO MEET OSHA EXPOSURE LIMITS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . USE BOOTS & PROTECTIVE CLOTHING.
Work Hygienic Practices:WASH SKIN & CLOTHING W/SOAP & WATER AFTER
CONTACT W/MATERIAL.
Supplemental Safety and Health
MP:>2000F,>1093C.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:SUPP DATA
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BROWN TO WHITE GRANULAR SOLID; NO DISTINCT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WHEN COMBINED W/WATER - HARDENS IN 1-8 HOURS W/EVOLUTION OF MODERATE
HEAT.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NO KNOWN HAZARDOUS DECOMPOSITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . DISPOSAL BY ORDINARY LAND FILL IN MODERATE QUANTITIES
& ACCORDANCE W/LOCAL REGULATIONS. NO SPECIAL DISPOSAL METHODS
REQUIRED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FAST DRY ACRYLIC ENAMEL, NON-LEAD GLOSS (SU
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:ING 10:TAKE INTERNALLY. KEEP OUT OF THE REACH OF CHILDREN.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:PRESENT AT HAZ LEVELS ONLY DURING
SANDING/ABRADING OF DRIED FILMS. IF NO SPECIFIC DUSTS ARE LISTED
IN(ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:ING SECTION, APPLIC LIMITS FOR NUISANCE DUSTS ARE
ACGIH TLV 10 MG/M3 (TOTAL DUST), OSHA PEL 15 MG/M3 (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:(TOTAL DUST), 5 MG/M3 (RESPIRABLE FRACTION).
RTECS #:9999999ZZ
Ingred Name:RESP PROT:RESP APPRVD BY NIOSH/MSHA FOR DUST WHICH MAY BE
GENERATED FROM PROD, UNDERLYING PAINT/ABRASIVE.
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
Ingred Name:VENT:LIMITS. REFER TO OSHA STANDARDS 1910.94, 1910.107,
1910.108.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP:W/PERM BRAIN & NERVOUS SYS DAM.
NOTE:TOLUENE (108-88-3) APPEARS ON NAVY LISTING OF OCCUP REPRO (ING
18)
RTECS #:9999999ZZ
Ingred Name:ING 17:HAZS. SEEK CONSULTATION FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE HANDLING (ING
19)
RTECS #:9999999ZZ
Ingred Name:ING 18:AND EXPOSURE RECOMMENDATIONS .
RTECS #:9999999ZZ
Ingred Name:MATLS TO AVOID:IN DANGEROUSLY INCREASED PRESS IN CLOSED
CONTAINERS.
RTECS #:9999999ZZ
Ingred Name:VM & P NAPHTHA. VP:12
CAS:64742-48-9
Fraction by Wt: 0-10%
OSHA PEL:300 PPM,400 PPM STEL
ACGIH TLV:300 PPM
Ingred Name:MINERAL SPIRITS. VP:2
CAS:64742-47-8
Fraction by Wt: 0-5%
OSHA PEL:500 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:TOLUENE (SARA III). VP:22
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 3-15%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BENZENE, ETHYL-;(ETHYLBENZENE) (SARA III). VP:7.1
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: <5%
OSHA PEL:100 PPM;125 STEL
ACGIH TLV:100 PPM;125 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE (SARA III). VP:5.9
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 30-45%
OSHA PEL:100 PPM;150 STEL
ACGIH TLV:100 PPM;150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETIC ACID, 2-METHOXY-1-METHYLETHYL
ESTER;(1-METHOXY-2-PROPANOL ACETATE). VP:1.8
CAS:108-65-6
RTECS #:AI8295000
Fraction by Wt: 0-5%
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 0-20%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:WASTE DISP METH:OF IN ACCORDANCE WITH FEDERAL, STATE, AND
LOCAL REGULATIONS REGARDING POLLUTION.
RTECS #:9999999ZZ
Ingred Name:HNDLG/STOR PREC:APPLIANCES, & ANY OTHER SOURCES OF IGNIT.
CONSULT NFPA CODE. USE APPROVED BONDING & GROUNDING (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:PROC. KEEP CNTNR CLSD WHEN NOT IN USE. TRANSFER ONLY
TO APPRVD CNTNRS W/COMPLETE & APPROP LABELING. DO NOT(ING 11)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRIT OF EYES, SKIN & RESP SYS.
MAY CAUSE NERVOUS SYS DEPRESS.EXTREME OVEREXPOS MAY RESULT IN UNCON
& POSS DEATH. HDCH, DIZZ, NAUS, & LOSS OF COORD ARE INDICATIONS OF
EXCESS EXPOS TO VAPS/SPRAYMISTS. REDNESS & ITCHING/BURNING
SENSATION MAY INDICATE EYE/EXCESS SKIN EXPOS. CHRONIC: PRLNGD(EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:OVEREXP TO SOLV INGS IN INGS SECTION
MAY CAUSE ADVERSE EFTS TO LIVER, URINARY, BLOOD FORMING,
CARDIO-VASCULAR/REPRO SYS. RATS EXPOS TO TITANIUM DIOXIDE DUST @
250 MG/M3 DEVELOPED LUNG CANCER, HOWEVER, SUCH EXPOS LEVELS ARE
NOT ATTAINABLE IN WORKPLACE. RPTS HAVE ASSOC RPTD/PRLNGD OCCUP
OVEREXPOS TO SOLV(ING 17)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM AND
QUIET. SKIN:WASH AFFECTED AREA THOROUGHLY WITH SOAP AND WATER.
REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE RE-USE. EYE:FLUSH
EYES WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES.
INGEST:CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:45F,7.2C
Lower Limits:0.7%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT
EQUIP.WATER SPRAY MAY BE INEFT. WATER IS USED, FOG NOZZ ARE PREF.
WATER MAY BE USED TO COOL CLSD CNTNRS(SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT/ELEC EQUIP/SPARKS & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOS TO EXTREME HEAT. APPLIC TO HOT SURF (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTENTS ARE FLAM. KEEP AWAY FROM
HEAT/SPARKS/OPEN FLAME. EXTING ALL FLAMES, PILOT LIGHTS, &
HEATERS-TURN OFF STOVES, ELEC TOOLS & (ING 9)
Other Precautions:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND
INHALING CONTENTS CAN BE HARMFUL OR FATAL. COATING CONTAINS MATLS
CLASSIFIED AS NUISANCE PARTICULATES, SUCH AS TITANIUM
DIOXIDE/CALCIUM CARBONATE W HICH MAY BE (ING 12)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERS EXPOS CANNOT BE CONTROLLED BELOW APPLIC
LIMITS BY VENT, WEAR PROPERLY FITTED ORGANIC VAP/PARTICULATE RESP
APPRVD BY NIOSH/MSHA FOR PROT AGAINST MATLS IN ING SECTION. WHEN
SANDING/ABRADING OF D RIED FILMS, WEAR DUST/MIST (ING 15)
Ventilation:LOCAL EXHAUST, PREF.GENERAL EXHAUST ACCEPTABLE IF EXPOS TO
MATLS IN ING SECTION IS MAINTAINED BELOW APPLIC EXPOS(ING 16)
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USING. USE ONLY W/ADEQUATE
VENTILATION. AVOID BRTHG VAPORS AND SPRAY MIST. AVOID CONTACT
W/SKIN & EYES.
Supplemental Safety and Health
MFR TRADE NAME/PART NO.:BLACK, F78 B 21. SPEC GRAV:0.934-1.13 . FIRE
FIGHT PROC:TO PREV PRESSURE BUILD-UP & POSS AUTOIGNIT/EXPLOSION
WHEN EXPOSED TO EXTREME HEAT. EXPLO HAZ:REQUIRE SPECIAL PREC.
DURING EMER CNDTNS OVEREXP TO DECOMP PROD MAY CAUSE HLTH HAZ. SYMPS
MAY NOT BE IMMED APPARENT. OBTAIN MD ATTENTION.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:>222F,>106C
Vapor Density:HVR/AIR
Spec Gravity:SUPP DATA
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:60-65
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
METALLICS CONTAIN ALUMINUM. CONTAM W/WATER, ACIDS, OR ALKALIS CAN CAUSE
EVOLUTION OF HYDROGEN, WHICH MAY RSLT (ING 20)
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE:CARBON DIOXIDE, CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM PROD MAY BE HAZ AS DEFINED UNDER
RESOURCE CONSERVATION & RECOVERY ACT (RCRA) 40 CFR 261. WASTE MUST
BE TESTED FOR IGNITABILITY TO DETERMINE APPLIC EPA HAZ WASTE
NUMBERS. INCIN IN APPRVD FAC ILITY. DO NOT INCIN CLSD CNTNRS. DISP
(ING 8)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:VIGORO LIQUID PLANT FOOD 12-4-6
Preparer's Name:W. L. HALL
CAGE:ESTEC
CAGE:ESTEC
============= Composition/Information on Ingredients =============
Ingred Name:NITROGEN
CAS:7727-37-9
RTECS #:QW9700000
Fraction by Wt: 12.0%
Other REC Limits:NONE SPECIFIED
ACGIH TLV:ASPHYXIANT; 9192
Ingred Name:PHOSPHORUS PENTOXIDE (SARA III)
CAS:1314-56-3
RTECS #:TH3945000
Fraction by Wt: 4.0%
Other REC Limits:NONE SPECIFIED
Ingred Name:POTASSIUM ARSENATE(SARA III)
CAS:7784-41-0
RTECS #:CG1100000
Fraction by Wt: 6.0%
Other REC Limits:NONE SPECIFIED
OSHA PEL:SEE 1910.1018
ACGIH TLV:0.2 MG AS/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE ESTABLISHED
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF EYES, SKIN AND
RESPIRATORY TRACT.IF SWALLOWED, CAUSES NAUSEA.
Effects of Overexposure:NONE
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:WASH OR FLUSH AREA IMMEDIATELY. IF SWALLOWED, INDUCE
VOMITING. CALL A PHYSICIAN IF IRRITATION PERSISTS.
===================== Fire Fighting Measures =====================
Flash Point:NA
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP OF SOAK UP EXCESS MATERIAL. RECYCLE IF
POSSIBLE. PLACT IN SUITABLE CONTAINER. FLUSH AREA WITH WATER.
AVOID CONTAMINATION OF STREAMS AND WATERWAYS.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP AWAY
FROM OTHER CHEMICALS.KEEP CONTAINERS CLOSED WHEN NOT IN USE.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE.
Ventilation:LOCAL EXHAUST IF NEEDED.
Other Protective Equipment:APRON AND WORK CLOTHING TO MINIMIZE
EXPOSURE. EYE WASH STATION & SAFETY SHOWER RECOMMENDED.
Work Hygienic Practices:WASH THOROUGHLY AFTER USE AND BEFORE EATING,
SMOKING OR USING TOILET FACILITIES. DO NOT BREATH VAPORS OR MIST.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NA
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:1.1 - 1.2
Evaporation Rate & Reference:NA
Solubility in Water:COMPLETE
Appearance and Odor:GREY OR BROWN LIQUID, LITTLE ODOR.
Percent Volatiles by Volume:NA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, ALKALIS, OXIDIZERS
Stability Condition to Avoid:HIGH HEAT
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE & LOCAL
REGULATIONS
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LOV-220 HIGH GLOSS VINYL COLOR
CAGE:29431
CAGE:29431
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC C8-C10 (AROMATIC
100) *91-4*
CAS:64742-95-6
Fraction by Wt: 8.6-9%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:CYCLOHEXANONE, KETOHEXAMETHYLENE
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: 12.5-13%
Other REC Limits:100PPM (SKIN) STEL
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:BUTYRIC ACID LACTONE, TETRAHYDRO-2-FURANONE, BLO
BUTYRYLACTONE
CAS:96-48-0
RTECS #:LU3500000
Fraction by Wt: 8-8.5%
ACGIH TLV:10 PPM
Ingred Name:LEAD CHROMATE, CR, CHROME GREEN, CHROME YELLOW (SUSPECTED
HUMAN CARCINOGEN BY ACGIH, IARC & NTP)
CAS:7758-97-6
RTECS #:GB2975000
Fraction by Wt: 9-14.7%
OSHA PEL:0.5 MG/CUM PB
ACGIH TLV:0.05 MG/CUM CR (A2)
Ingred Name:CHROMIUM METAL, CHROMIUM, CHROME (SUSPECTED A1 HUMAN
CARCINOGEN BY IARC, NTP & ACGIH)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 2.5-6.4%
OSHA PEL:1 MG/CUM
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:EYES: IRRITATION & DAMAGE. SKIN:
IRRITATION, DAMAGE, DRYNESS & REDNESS. INHALATION: RESPIRATORY
TRACT IRRITATION, DIZZINESS, HEADACHE, NAUSEA, VOMITING, DAMAGE TO
KIDNEYS/LIVER/CENTRAL NERVOUS SYSTEM & LOSS OF CONSCIOUSNESS.
Explanation of Carcinogenicity:LEAD & CHROMATES ARE SUSPECTED HUMAN
CARCINOGENS BY ACGIH.
Effects of Overexposure:EYES: IRRITATION & DAMGE. SKIN: IRRITATION,
DAMAGE, DRYNESS & REDNESS. INHALATION: RESPIRATORY TRACT
IRRITATION, DIZZINESS, HEADACHE, NAUSEA, VOMITING, DAMAGE TO
KIDNEYS/LIVER/CENTRAL NERVOUS SYSTEM & LOSS OF CONSCIOUSNESS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER.
INHALATION: REMOVE TO FRESH AIR. IF UNCONSCIOUS, APPLY CPR IF
NEEDED. INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION
IN ALL CASE S.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:111F
Lower Limits:1%
Upper Limits:6.9%
Extinguishing Media:WATER FOG, ALCOHOL FOAM, CO2 & DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS. USE
WATER FOG TO COOL CONTAINERS.
Unusual Fire/Explosion Hazard:VAPORS MAY FORM EXPOSIVE MIXTURES W/AIR.
EMPTY CONTAINERS COULD IGNITE EXPLOSIVELY.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. ABSORB W/SAND.
WEAR PROTECTIVE CLOTHING. PUMP INTO SALVAGE TANK. KEEP MATERIAL OUT
OF SEWERS, STREAMS ETC.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING. OVERHEATING MAY
CAUSE CONTAINER TO RUPTURE. AVOID CONTACT W/EYES/SKIN & INHALATION.
DON'T TAKE INTERNALLY.
Other Precautions:CHECK ALL CONTAINERS FOR LEAKS. KEEP CONTAINERS COOL,
DRY & AWAY FROM IGNITION SOURCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE MSHA/NIOSH APPROVED VAPOR RESPIRATOR.
Ventilation:LOCAL & MECHANICAL EXHAUST TO KEEP <TLV.
Other Protective Equipment:EYEWASH STATION, IMPERVIOUS CLOTHING & BOOTS
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING. WASH THOROUGHLY
AFTER HANDLING.
Supplemental Safety and Health
BOILING RANGE: 308-415F.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:SEE SUPP.
Vapor Pres:1.28-1.31
Vapor Density:3.76-3.79
Spec Gravity:1.222-1.312
Evaporation Rate & Reference:(BU AC = 1): SLOWER
Solubility in Water:<0.1%
Appearance and Odor:COLORED PASTE W/MILD ODOR
Percent Volatiles by Volume: 58-60
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ALKALIES & MINERAL ACIDS
Stability Condition to Avoid:EXTREME COLD/HEAT, ELEVATED TEMPERATURES,
OTHER IGNITION SOURCES & FREEZING
Hazardous Decomposition Products:ACRID SMOKE, CO, CO2, VARIOUS
HYDROCARBONS & NOXIOUS GASES
Conditions to Avoid Polymerization:DROPPING OR PUNCTURE OF CONTAINERS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:57262 AHG GREEN MONOCLONAL/POLYSPECIFIC
CAGE:67018
CAGE:67018
CAGE:67823
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM AZIDE, AZIDE *98-1*
CAS:26628-22-8
RTECS #:VY8050000
Fraction by Wt: 0.1%
Other REC Limits:0.1 PPM
ACGIH TLV:C 0.29 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 27 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF SWALLOWED. MAY BE ABSORBED
THROUGH SKIN. MAY CAUSE ALLERGENIC REACTION IN SUSCEPTIBLE
INDIVIDUALS.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH THOROUGHLY W/WATER FOR 15 MINS. SKIN: RINSE
W/PLENTY OF WATER FOR 15 MINS. INHALATION: AID IN BREATHING IF
NECESSARY. INGESTION: FLUSH MOUTH. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:DRY CHEMICAL/CO2
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: WEAR PROTECTIVE CLOTHING TO GUARD
AGAINST EYE & SKIN CONTACT. USE SPILL PILLOWS/OTHER APPROPRIATE
ABSORBENT. PLACE MATERIALS IN SEALED CONTAINER FOR PROPER DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BETWEEN 35.6F-46.4F. DON'T STORE
NEAR ACIDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED, UNDER NORMAL PRODUCT USE.
Ventilation:USE W/ADEQUATE VENTILATION.
Other Protective Equipment:CHEMICAL RESISTANT APRON, PROTECTIVE
CLOTHING.
Work Hygienic Practices:GOOD HYGIENE PRACTICES SHOULD BE FOLLOWED TO
AVOID EYE & SKIN CONTACT W/THIS PRODUCT.
Supplemental Safety and Health
WHILE THE PRODUCTS LISTED ARE NOT CONSIDERED HAZARDOUS AS DEFINED BY
OSHA, BCA WOULD LIKE TO MAKE YOU AWARE OF THE FOLLOWING HANDLING
PRECAUTIONS: THESE PRODUCTS CONTAIN 0.1%/LESS SODIUM AZIDE AS A PR
ESERVATIVE. THEREFORE, WE HAVE ENCLOSEDA MSDS FOR 0.1% SODIUM
AZIDE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Vapor Pres:AS WATER
Evaporation Rate & Reference:(WATER=1): 1
Appearance and Odor:COLORLESS LIQUID W/NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS
Hazardous Decomposition Products:TOXIC GAS, MAY FORM EXPLOSIVE
LEAD/COPPER IN LABORATORY PLUMBING
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS. MAY FORM EXPLOSIVE LEAD/COPPER AZIDE IN
LABORATORY PLUMBING.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LIQUID TRI-DET
CAGE:0DAC4
CAGE:0DAC4
CAGE:85884
============= Composition/Information on Ingredients =============
Ingred Name:BACILLUS SUBTILIS CARLSBERG; (PROTEASE ENZYME)
CAS:9014-01-1
RTECS #:CO9550000
Fraction by Wt: 1-5%
OSHA PEL:0.00006 MG/M3, C
ACGIH TLV:0.00006 MG/M3, C
Ingred Name:ENZYME; (AMYLASE ENZYME)
CAS:9000-85-5
Fraction by Wt: <5%
Other REC Limits:1.8 MCG/ME (MFR)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BENZENESULFONIC ACID, DODECYL-, POTASSIUM SALT; (POTASSIUM
DODECYLBENZENE SULFONATE)
CAS:27177-77-1
RTECS #:DB6820000
Fraction by Wt: 5-15%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:NONYLPHENOL POLYETHOXATE; (NONYLPHENOL ETHOXYLATE)
CAS:9016-45-9
RTECS #:MD0900000
Fraction by Wt: 10-20%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TRIETHANOLAMINE SOAP OF ROSIN ACIDS; (TRIETHANOLAMINE
SOAPS)
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN AND EYES:MAY CAUSE IRRITATION.
INGESTION:MAY CAUSE STOMACH DISTRESS, NAUSEA OR VOMITING.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:IF IRRIT/DISCOMFORT PERSISTS, CALL MD. INHAL:REMOVE TO FRESH
AIR. SUPPORT BRTHG (GIVE O*2/ARTF RESP) . EYES:FLUSH IMMED W/PLENTY
OF COOL RUNNING WATER. REMOVE CONTACT LENSES. HOLDING EYELIDS APA
RT, CONTINUE FLUSHING FOR AT LST 15 MINS. SKIN:FLUSH W/PLENTY OF
COOL RUNNING WATER. WASH THORO W/SOAP & WATER. INGEST:RINSE MOUTH;
THEN DRINK 1-2 LG GLASSES OF WATER. DO NOT INDUCE VOMIT. (SUPP
DATA)
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE . PRODUCT DOES
NOT SUPPORT COMBUSTION.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PROTECTIVE EQUIPMENT. DIKE OR DAM
LARGE SPILLS. PUMP TO CONTAINERS OR SOAK UP ON INERT ABSORBENT.
FLUSH RESIDUE TO SANITARY SEWER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NO REQUIREMENTS BEYOND STANDARD INDUSTRIAL
HYGIENE PRACTICES.
Supplemental Safety and Health
FIRST AID PROC:NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Spec Gravity:1.069-1.089
pH:7-8.5
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIQUID; FLORAL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:DO NOT MIX W/ANYTHING BUT WATER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . CONSULT STATE & LOCAL AUTHORITIES FOR RESTRICTIONS ON
DISPOSAL OF CHEMICAL WASTE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:368 9379 KODAK RA4011 WASH ADDITIVE, WORKING SOLUTION
CAGE:0W260
CAGE:19139
CAGE:5K871
CAGE:0W260
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: >99%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIPROPYLENE GLYCOL
CAS:110-98-5
RTECS #:UB8785000
Fraction by Wt: <0.1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ISOTHIAZOLONES
Fraction by Wt: <0.05%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: EXPECTED TO BE A LOW
HAZARD FOR RECOMMENDED HANDLING. EYES: NO SPECIFIC HAZARD KNOWN.
MAY CAUSE TRANSIENT IRRITATION. SKIN: LOW HAZARD FOR RECOMMENDED
HANDLING. INGESTION: EXPECTED TO BE A LOW INGESTION HAZARD.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION-IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSISTS. EYES-ANY MATERIAL THAT CONTENTS THE
EYE SHOULD BE WASHED OUT IMMEDIATELY WITH WATER. GET MEDICAL
ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH SOAP & WATER. GET
MEDICAL ATTENTION FOR SYMPTOMS. INGESTION: DRINK 1-2 GLASSES OF
WATER. SEEK MEDICAL ATTENTION. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE APPROPIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:NONE.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER.
OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT MATERIAL,
THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN SURFACE
THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED.
Other Precautions:AVOID CONTACT WITH EYES, SKIN AND CLOTHING. USE WITH
ADQEUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES/HR)
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:EYE BATH, SAFETY SHOWER, WASHING FACILITIES.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. IT IS A GOOD
INDUSTRIAL HYGIENE PRACTICE TO MINIMIZE EYE CONTACT.
Supplemental Safety and Health
KEEP OUT OF REACH OF CHILDREN.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:18 MMHG
Vapor Density:0.6
Spec Gravity:1.00
pH:7.0
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID. COLORLESS. ODORLESS.
Percent Volatiles by Volume:>99
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE WITH COMMON MATERIALS AND CONTAMINANTS WITH WHICH THE MATERIAL MAY
REASONABLY COME INTO CONTACT.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE, OR LOCAL LAWS. FLUSH TO SEWER WITH LARGE
AMOUNTS OF WATER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:3090 DPP INK COLORS FOR PAPER/VELLUM, YELLOW
CAGE:JO336
CAGE:JO336
CAGE:75364
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 74-85%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ORGANIC DYESTUFF
Fraction by Wt: 3.0-6.5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:GLYCEROL; (GLYCERIN)
CAS:56-81-5
RTECS #:MA8050000
Fraction by Wt: 10-16%
OSHA PEL:15 MG/M3 (MIST)
ACGIH TLV:10 MG/M3 (MIST);9495
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT WITH EYE MAY CAUSE IRRITATION,
PROLONGED CONTACT WITH SKIN MAY CAUSE IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:REDNESS OF EYE AND SKIN.
Medical Cond Aggravated by Exposure:NONE EXPECTED.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . EYES: FLUSH IMMEDIATELY WITH WATER FOR AT LEAST 15 MINUTES,
GET MEDICAL ATTENTION. SKIN: FLUSH WITH WATER, WASH WITH SOAP AND
WATER. INGESTION: DRINK 1 OR 2 GLASSESOF WATER TO DILUTE, GET
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:WASH WITH SOAP AND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID TEMPERATURE EXTREMES.
Other Precautions:KEEP FROM FREEZING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NECESSARY. NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NOT APPLICABLE.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
TOILET FACILITES.
Supplemental Safety and Health
SPEC GRAV: 1.04-1.05 (H*2O = 1)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>209F,>98C
Melt/Freeze Pt:M.P/F.P Text:>16F,>-9C
Vapor Pres:LIKE WATER
Vapor Density:LIKE WATER
Spec Gravity:SUPDAT
Evaporation Rate & Reference:LIKE WATER
Solubility in Water:MISCIBLE
Appearance and Odor:LOW VISCOSITY PRODUCT, MILD ODOR AND COLOR FROM
DYESTUFF.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OXIDES OF CARBON, NITROGEN, AND
SULFUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:BURY, INCINERATE OR FLUSH INTO SEWER IN
ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: POOL STAIN TREAT
Cage: UNCHM
Box: 429
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: UNCHM
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: SKIN: CAN CAUSE IRRITATION OR CORROSIVE BURNS. EYES: CAN
CAUSE IRRITATION, CORNEAL BURNS, CONJUNCTIVITIS.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTIFICIAL
RESPIRATION) (FP N). SKIN:PROMPTLY FLUSH W/PLENTY OF WATER FOR AT LEAST 15
MINUTES. EYES:PROMPTLY FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINUTES.
INGESTION:DRINK LARGE AMOUNTS OF MILK TO DILUTE AND NEUTRALIZE THE ACID. DO
NOT INDUCE VOMITING!!!
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SWEEP AND SHOVEL UP INTO CONTAINER. NEUTRALIZE AREA
WITH ALKALI SOLUTION.
Neutralizing Agent: ALKALI SOLUTION.
Waste Disposal Methods: NEUTRALIZE WITH ALKAI SOLUTION AND FLUSH TO SEWER WITH
PLENTY OF WATER IF PERMITTED BY APPLICABLE FEDERAL, STATE, LOCAL DISPOSAL
REGULATIONS. NEUTRALIZED WASTE MAY HAVE TO BE DISPOSED OF BY AN APPROVE D
CONTRACTOR.
Handling And Storage Precautions: STORE IN COOL DRY PLACE AWAY FROM FOOD, FOOD
CHEMICALS OR STRONG OXIDIZERS.
Other Precautions: AVOID CONTACT WITH ORGANIC MATERIAL. WHEN DISSOLVING, ADD
SOLID MATERIAL CAUTIOUSLY TO WATER WITH STIRRING AND AVOID SPLASHING.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONE
Extinguishing Media: MEDIA SUITABLE FOR SURROUNDING FIRE (FP N).
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N). FORMIC ACID AND CARBON MONOXIDE GASSES MAY BE PRESENT.
Unusual Fire/Explosion Hazard: PARTIAL DECOMP OCCURS AT 150C. DECOMP PRODS
INCLUDE CARBON MONOXIDE AND FORMIC ACID, WHICH ARE BOTH TOXIC AND FLAMM. CAN
REACT VIOLENTLY W/STRONG OXIDIZERS.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH/MSHA APPROVED DUST RESPIRATOR WHERE DUSTING
OCCURS.
Ventilation: NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment: CLOTHING TO MINIMIZE SKIN CONTACT. EMERGENCY EYE
WASH & DELUGE SHOWER (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: SOL IN H*2O: 13.7% SOLUTION @ 25C. MATLS TO
FULL LENGTH FACESHIELD (FP N).
=======================================================
Physical/Chemical Properties
=======================================================
M.P/F.P Text: 215F,102C
Spec Gravity: 1.653 (H*2O=1)
Solubility in Water: APPRECIABLE (SUPDAT)
Appearance and Odor: COLORLESS CRYSTALS, ODORLESS.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: STRONG OXIDIZERS.
Materials To Avoid: REACTS W/ALKALI, DECOMPOSES @ HIGH TEMPS >150C. REACTS
W/SOME SILVER CMPDS TO FORM EXPLO SILVER OXALATE CAN (SUPDAT)
Hazardous Decomposition Products: FORMIC ACID, CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: POOL STAIN TREAT
Cage: UNCHM
Company Name: UNITED CHEMICAL CORP
Street: 3741 E TELEGRAPH RD
Zipcode: 93040
Label Required IND: Y
Date Of Label Review: 04/05/1993
Status Code: C
Label Date: 04/05/1993
Origination Code: G
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Severe
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: CORROSIVE! CONTACT W/EYES AND SKIN MAY CAUSE
BURNS. REACTS VIOLENTLY WITH STRONG OXIDERS. REACTS W/SILVER COMPOUNDS TO
FORM EXPLOSIVE SILVER OXALATE. CHRONIC: NONE LISTED BY MANUFACTURER.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MANZATE 200 DF FUNGICIDE
CAGE:18773
CAGE:18773
CAGE:18873
============= Composition/Information on Ingredients =============
Ingred Name:INERT INGREDIENTS (TYPE NOT SPECIFIED)
Fraction by Wt: 25%
Ingred Name:MANCOZEB
CAS:8018-01-7
RTECS #:ZB3200000
Fraction by Wt: 75%
Other REC Limits:1.5 MG/CUM
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 >5000 MG/KG ORAL
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY IRRITATE EYES, NOSE,
THROAT & SKIN. MAY BE HARMFUL IF INHALED OR SWALLOWED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: MAY IRRITATE EYES, NOSE, THROAT &
SKIN. MAY BE HARMFUL IF INHALED OR SWALLOWED. EYE: SEVERE CORNEAL
OPACITY.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRATION, PREFERABLY MOUTH-TO-MOUTH. IF BREATHING IS
DIFFICULT, GIVE OXYGEN. CALL PHYSICIAN. EYE/SKIN: FLUSH WITH PLENTY
OF WATER FOR AT LEAST 15 MINUTES. CALL PHYSICIAN. INGESTION:
INDUCE VOMITING IMMEDIATELY BY GIVING 2 GLASSES OF WATER & STICKING
FINGER DOWN THROAT. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON.
===================== Fire Fighting Measures =====================
Lower Limits:0.29%
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEMICAL, CO2
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS. COOL
TANK/CONTAINER W/WATER SPRAY. IF CONDITIONS PERMIT, LET FIRE BURN
ITSELF OUT, WATER COULD CAUSE CONTAMINATION.
Unusual Fire/Explosion Hazard:DUST FORMS EXPLOSIVE MIXTURE WITH AIR.
DANGEROUS WHEN WET. WATER LEADS TO CHEMICAL CHANGES & CREATES
FLAMMABLE VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:USE APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT
DURING CLEAN UP. REMOVE SOURCE OF HEAT, SPARKS, FLAME, IMPACT,
FRICTION OR ELECTRICITY. DIKE SPILL. PREVENT LIQUID FROM ENTERING
SEWERS, WATER WAYS OR LOW AREAS. SHOVEL OR SWEEP UP.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN WELL VENTILATED AREA. KEEP
CONTAINER TIGHTLY CLOSED. DON'T STORE/CONSUME FOOD, DRINK OR
TOBACCO IN AREA WHERE THEY MAY BECOME CONTAMINATED.
Other Precautions:NEVER ALLOW PRODUCT TO BECOME WET DURING STORAGE.
THIS MAY LEAD TO CHEMICAL CHANGES WHICH WILL REDUCE THE
EFFECTIVENESS AS A FUNGICIDE/CREATE FLAMMABLE VAPORS. AVOID
BREATHING OF VAPORS/MIST. AVOID CO NTACT WITH EYES, SKIN &
CLOTHING.
============= Exposure Controls/Personal Protection =============
Ventilation:USE ONLY WITH ADEQUATE VENTILATION
Other Protective Equipment:WEAR PROTECTIVE CLOTHING INCLUDING LONG
OPERATIONS.
Work Hygienic Practices:DON'T CONSUME FOOD, DRINK OR TOBACCO IN THE
AREAS WHERE THEY MAY BECOME CONTAMINATED WITH THIS MATERIAL.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:DISPERSES
Appearance and Odor:YELLOW; SULFUROUS ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, MOISTURE
Stability Condition to Avoid:HEAT, SPARKS & OPEN FLAMES
Hazardous Decomposition Products:OXIDES OF SULFUR & NITROGEN. ELEVATED
TEMP OR FREE WATER PROMOTES DECOMPOSITION WHICH MAY CAUSE
SPONTANEOUS COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:TREATMENT, STORAGE, TRANSPORTATION & DISPOSAL
MUST BE IN ACCORDANCE WITH FEDERAL, STATE, & LOCAL REGULATIONS.
DON'T FLUSH TO SURFACE WATER OR SANITARY SEWER SYSTEM. DISPOSE OF
EMPTY BAG IN A SANITARY LANDFILL OR BY INCINERATION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BRAYCO MICRONIC 881
CAGE:EO288
CAGE:EO288
DIV
CAGE:2R128
CAGE:0T5C6
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
= Wt:100.
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: EYES, SKIN, RESPIRATORY
AND GASTROINTESTINAL TRACTS. EYES - MAY CAUSE EYE IRRITATION. SKIN
CONTACT - CONCENTRATION MAY CAUSE SKIN IRRITATION. INGESTION - THIS
PRODUCT MAY CAUSE GASTROIN TESTINAL DISTRESS. INHALATION -
INHALATION OF HIGH CONCENTRATIONS OF MISTS MAY PRODUCE IRRITATION
AND DAMAGE TO THE RESPIRATORY TRACT. CHRONIC - NONE.
Explanation of Carcinogenicity:NOT CARCINOGENIC.
Effects of Overexposure:NAUSEA, VOMITING, DIARRHEA, AND ABDOMINAL PAIN,
IRRITATION, COUGHING, TEARING
Medical Cond Aggravated by Exposure:PREEXISTING DISEASES OF THE EYES,
SKIN, RESPIRATORY TRACT MAY BE AGGRAVATED BY OVEREXPOSURE TO THIS
PRODUCT.
======================= First Aid Measures =======================
First Aid:EYE - FLUSH EYE WITH PLENTY OF WATER. GET MEDICAL ATTENTION
IF IRRITATION OCCURS. SKIN - WASH SKIN WITH PLENTY OF SOAP & WATER.
REMOVE CONTAMINATED CLOTHES. INGESTION - ASPIRATION HAZARD, DO NOT
INDUC E VOMITING OR GIVE ANYTHING BY MOUTH. IFVOMITING OCCURS,
PLACE VICTIM ON THE LEFT SIDE WITH HEAD DOWN. INHALATION - REMOVE
FROM EXPOSURE AREA TO FRESH AIR IMMEDIATELY. IF BREATHING STOPS,
PERFORM ARTI FICIAL RESPIRATION. KEEP PERSON WARM AND AT REST. GET
MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:=182.C, 359.6F
Lower Limits:ND
Upper Limits:ND
Extinguishing Media:WATER, DRY CHEMICAL, CARBON DIOXIDE OR ALCOHOL
FOAM.
Fire Fighting Procedures:CONTACT WITH WATER WILL CAUSE SPATTERING AND
MAY GENERATE ENOUGH HEAT TO IGNITE COMBUSTIBLE MATERIAL.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR APPROPIATE PROTECTIVE CLOTHING. STOP
SOURCE OF LEAK IF POSSIBLE. DIKE, CONTAIN SPILL & RECOVER FREE
LIQUID. PREVENT ENTRY WATERWAYS. SOAK UP RESIDUE WITH AN INERT
ABSORBENT SUCH AS CLAY, SAND OR OTHER SUITABLE MATERIAL; STORE &
DISPOSEOF PROPER
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:MAINTAIN AMBIENT TEMPERATURES. AVOID
PROLONGED/REPEATED BREATHING OF VAPORS, MISTS, FUMES. KEEP
CONTAINER TIGHTLY CLOSED.
Other Precautions:DO NOT STORE NEAR HEAT, FLAME, STRONG OXIDANTS.
MAINTAIN ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR WITH ORGANIC
VAPOR CARTRIDGE IF VAPOR CONCENTRATIONS EXCEEDS PERMISSIBLE
EXPOSURE LIMITS.
Ventilation:PROVIDE SUFFICIENT MECHANICAL, GENERAL, AND/OR LOCAL
EXHAUST TO MAINTAIN EXPOSURE BELOW TLV. GREATER THAN 60F3/M.
Other Protective Equipment:EYE BATH, WASHING FACILITY, EMERGENCY
SHOWER, LAB COAT OR UNIFORM.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:>260.C, 500.F
Vapor Pres:ND
Vapor Density:ND
Spec Gravity:0.8400
Evaporation Rate & Reference:ND
Solubility in Water:SLIGHT
Appearance and Odor:PALE,K STRAW COLORED FLUID, MILD PETROLEUM ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:HEAT AND SOURCES OF IGNITION.
Hazardous Decomposition Products:IRRITATING OR TOXIC FUMES, CARBON
DIOXIDE, CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. DISPOSAL OF THIS MATERIAL TO THE LAND MAY BE
BANNED BY FEDERAL LAW. MAY BE DISPOSED OF BY CONTROLLED
INCINERATION.
=================== MSDS Transport Information ===================
Transport Information:NOT REGULATED (IF SHIPPED BY LAND IN NON BULK
PACKAGING)
===================== Regulatory Information =====================
Federal Regulatory Information:THIS PRODUCT, AS PURCHASED, DOES NOT
MEET THE RCRA CRITERIA OF A HAZARDOUS WASTE. UNDER RCRA, IT IS THE
RESPONSIBILITY OF THE USER TO DETERMINE WHETHER PRODUCT MEETS RCRA
CRITERIA FOR HAZARDOUS WASTE. HAZARDOUS PER OSHA 29 CFR 1910.1200.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:XTRA LATEX SEMI-GLOSS PAINT YA 113
CAGE:01PD6
CAGE:01PD6
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM OXIDE
CAS:13463-67-7
RTECS #:XR2275000
Minumum % Wt:10.
Maxumum % Wt:20.
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Minumum % Wt:50.
Maxumum % Wt:60.
Ingred Name:ACETIC ACID ETHENYL ESTER
CAS:108-05-4
RTECS #:AK0875000
< Wt:1.
OSHA PEL:10 PPM
OSHA STEL:20 PPM
ACGIH TLV:10 PPM
ACGIH STEL:20 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:1,2-PROPANEDIOL
CAS:57-55-6
RTECS #:TY2000000
Minumum % Wt:1.
Maxumum % Wt:5.
Ingred Name:ETHANOL, 2,2'-OXYBIS-
CAS:111-46-6
RTECS #:ID5950000
Minumum % Wt:1.
Maxumum % Wt:5.
Ingred Name:BUTYL ACRYLATE-VINYL ACETATE POLYMER
CAS:25067-01-0
Minumum % Wt:10.
Maxumum % Wt:20.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:PRODUCTS IN THIS SERIES MAY CONTAIN
VINYL ACETATE WHICH HAS CAUSED TREATMENT RELATED NASAL TUMORS IN
RATS AND MICE EXPOSED VIA INHALATION FOR TWO YEARS.
Effects of Overexposure:INHALATION: IRRITATION OF RESPIRATORY TRACT.
PROLONGED INHALATION MAY LEAD TO DROWSINESS, DIZZINESS AND/OR
LIGHTHEADEDNESS. SKIN: IRRITATION OF SKIN. CAN CAUSE DERMATITIS,
DEFATTING.EYE: IRRITAT ION OF EYES. CAN CAUSE TEARING OF EYES,
REDNESS OF EYES, SEVERE EYE IRRITATION. INGESTION: MAY CAUSE
FATIGUE, DROWSINESS, DIZZINESS AND/OR LIGHTHEADEDNESS,
UNCOORDINATION, NAUSEA, VOMITING AND DIARR HEA.
Medical Cond Aggravated by Exposure:INGREDIENTS CONTAINED IN THESE
PRODUCTS HAVE BEEN REPORTED TO AGGRAVATE PREEXISTING EYE, SKIN AND
RESPIRATORY, KIDNEY, LIVER, AND NERVOUS SYSTEM DISORDERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE AND SUPPORT
BREATHING.HAVE TRAINED PERSON GIVE OXYGEN IF NECESSARY. SKIN:
WASH OFF QUICKLY WITH PLENTY OF WATER, THEN SOAP AND WATER; REMOVE
CONTAMINATED C LOTHING. WASH CONTAMINATED CLOTHING BEFORE REUSE.
EYE: FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF WATER, ESPECIALLY
UNDER LIDS FOR AT LEAST 15 MINUTES. INGESTION: IF SWALLOWED, OBTAIN
MEDICAL TREATMENT IMMEDIATELY! IN ALL CASES, SEEK IMMEDIATE
MEDICAL ATTENTION!
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:WATER MAY BE USED TO COOL AND PROTECT EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY BURST IF EXPOSED
TO EXTREME HEAT OR FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:COMPLY WITH ALL APPLICABLE HEALTH AND
ENVIRONMENTAL REGULATIONS. VENTILATE AREA. SPILLS MAY BE COLLECTED
WITH ABSORBENT MATERIALS. COMPLETE PERSONAL PROTECTIVE EQUIPMENT
MUST BE USED DURING CLEANUP.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 100 F. KEEP AWAY FROM
HEAT, SPARKS AND OPEN FLAME. KEEP FROM FREEZING.
Other Precautions:USE ONLY WITH ADEQUATE VENTILATION. DO NOT TAKE
INTERNALLY. KEEP OUT OF REACH OF CHILDREN. AVOID CONTACT WITH SKIN
AND EYES, AND BREATHING OF VAPORS. WASH HANDS THOROUGHLY AFTER
HANDLING, ESPECIALLY B EFORE EATING OR SMOKING. KEEP CONTAINERS
TIGHTLY CLOSED AND UPRIGHT WHEN NOT IN USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW
APPLICABLE STANDARDS. WHERE RESPIRATORY PROTECTION IS REQUIRED,
USE ONLY NIOSH/MSHA APPROVED RESPIRATORS IN ACCORDANCE WITH OSHA
STANDARD 29 CFR 1910.134.
Ventilation:PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT
BUILD-UP OF VAPORS.
Other Protective Equipment:EYE WASH, SAFETY SHOWER
Supplemental Safety and Health
WT/GAL: 9.8
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:162-212 F
Percent Volatiles by Volume:68.4
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, METALS, ACIDS, ALCOHOLS, MAGNESIUM.
Stability Condition to Avoid:ELEVATED TEMPERATURES, CONTACT WITH
OXIDIZING AGENT, FREEZING.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
=================== Toxicological Information===================
Toxicological Information:ORAL CONSUMPTION OF PRODUCTS CONTAINING
ETHYLENE GLYCOL MAY PRODUCE ADVERSE HEALTH EFFECTS.INGESTION OF
LARGE VOLUMES OF ETHYLENE GLYCOL MAY RESULT IN KIDNEY DAMAGE &/OR
FAILURE.STUDIES W/ LABORATORY ANIMALS SHOW THAT HIGH DOSES OF
ETHYLENE GLYCOL, ADMINISTERED ORALLY,PRODUCE BIRTH DEFECTS IN RATS
& MICE.THERE IS,HOWEVER,NO CURRENTLY AVAILABLE INFORMATION TO
SUGGEST THAT ETHYLENE GLYCOL HAS CAUSED BIRTH DEFECTS IN HUMANS.A
STUDY CONDUCTED BY NTP,USING A CONTINUOUS BREEDING PROTOCOL
DEMONSTRATED THAT DIETHYLENE GLYCOL ADMINISTERED IN DRINKING WATER
AT A CONCENTRATION OF 3.5% RESULTED IN DECREAS ED FERTILITY&
REPRODUCTIVE PERFORMANC
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
=================== MSDS Transport Information ===================
Transport Information:DOT PROPER SHIPPING NAME: PAINT.
===================== Regulatory Information =====================
SARA Title III Information:SARA 302: VINYL ACETATE; SARA 313: VINYL
ACETATE
Federal Regulatory Information:CERCLA: VINYL ACETATE
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PA2001, HYSOL PC16M, PART A
Kit Part:Y
Resp. Party Other MSDS Num.:PA2001
CAGE:04347
CAGE:04347
Contract Num:SP0430-01-M-NS55
CAGE:7B953
============= Composition/Information on Ingredients =============
Ingred Name:PHENOL, 4,4-(1-METHYLETHYLHYLIDE
CAS:25068-38-6
RTECS #:CE6880000
Minumum % Wt:60.
Maxumum % Wt:100.
Ingred Name:OXIRANE, (BUTOXYMETHYL)-
CAS:2426-08-6
RTECS #:TX4200000
Minumum % Wt:5.
Maxumum % Wt:10.
OSHA PEL:270 MG/M3;50 PPM
ACGIH TLV:133 MG/M3;25 PPM
Ingred Name:1,2-BENZENEDICARBOXYLIC ACID, DIBUTYL ESTER
CAS:84-74-2
RTECS #:TI0875000
Minumum % Wt:10.
Maxumum % Wt:30.
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE-CONTACT MAY CAUSE EYE IRRITATION.
SKIN-PROLONGED OR REPEATED SKIN CONTACT MAY CAUSE IRRITATION.
INHALATION-HARMFUL IF INHALED, MAY CAUSE ALLERGIC RESPIRATORY
REACTION SUCH AS ASTHMA. INGESTION-MOD ERATELY TOXIC. TARGET
ORGANS: INGREDIENTS MAY BE TOXIC TO THE FOLLOWING ORGANS; EYES,
SKIN, RESPIRATORY TRACT.
Explanation of Carcinogenicity:NOT LISTED.
Effects of Overexposure:SKIN-CONTACT WITH PRODUCT AT ELEVATED
TEMPERATURES (>150C) CAN RESULT IN THERMAL BURNS. INGESTION-MAY
CAUSE VOMITING.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN & EYE DISORDERS
MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT. PREEXISTING SKIN OR
LUNG ALLERGIES MAY INCREASE THE CHANCE OF DEVELOPING INCREASED
ALLERGIC SYMPTOMS FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYE-IMMEDIATELY WASH/FLUSH WITH WATER FOR MINIMUM 10 MINS.
SEEK MEDICAL ATTENTION. SKIN-WASH OFF IN FLOWING WATER OR SHOWER.
REMOVE CONTAMINATED CLOTHING/SHOES. SEEK MEDICAL ATTENTION, IF
IRRITATION D EVELOPS. INHALATION-MOVE TO FRESH AIR. IF NOT
BREATHING, GIVE MOUTH TO MOUTH RESUSCITATION. IF BREATHING IS
DIFFICULT, GIVE OXYGEN. SEEK MEDICAL ATTENTION. INGESTION-IF
SWALLOWED, DO NOT INDUCE VOMITI NG. SEEK PROMPT MEDICAL ATTENTION.
NOTE TO PHYSICIAN: TREATMENT SHOULD BE DIRECTED AT THE CONTROL OF
SYMPTOMS & THE CLINICAL CONDITIONS. ANTIDOTE: THERE ARE NO SPECIFIC
ANTIDOTES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:=68.3C, 155.F
Extinguishing Media:WATER FOG, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:RECOMMENDED USE OF SELF CONTAINED BREATHING
APPARATUS (SCBA).
Unusual Fire/Explosion Hazard:NO UNUSUAL FIRE OR EXPLOSION HAZARDS.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL IN NATURAL FORM OR WITH SAND OR
DIRT (INERT MATERIAL). ELIMINATE ALL IGNITION SOURCES. PREVENT
RUNOFF TO STORM SEWERS, DITCHES & WATERWAYS. SHOVEL OR SCRAPE
(NON-METALLIC) ABSORBED WASTE MATERIAL INTO DISPOSAL CONTAINER.
SEAL LID TIGHTLY WITH TAPE OR LOCKING RING & LABEL PROPERLY. CLEAN
UP SPILL IMMEDIATELY, OBSERVING PRECAUTIONS INCLUDING ADEQUATE
VENTILATION &/OR PPE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLING-PLASTIC CONTAINERS MAY BE
SLIPPERY WHEN HANDLING. STORAGE-LESS THAN TWENTY FIVE DEGREES
CENTRIGRADE (<25C) (77F) FOR OPTIMUM SHELF LIFE. DRY ATMOSPHERIC
CONDITIONS. KEEP CONTAINERS CLOSED & T IGHTLY SEALED.
Other Precautions:GENERAL COMMENTS: DO NOT EXPOSE TO DIRECT SUNLIGHT.
ONCE CONTAINER IS OPEN, USE NITROGEN BLANKET ON MATERIAL & RESEAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO RESPIRATOR IS REQUIRED IF INGREDIENTS
EXPOSURE LIMITS ARE NOT EXCEEDED. AN OSHA APPROVED RESPIRATOR (29
CFR 1910.134 USA DEPT OF LABOR), AIR-PURIFYING RESPIRATOR WITH
APPROPRIATE CARTRIDGE SHOULD B E USED IF EXPOSURE LIMITS ARE
EXCEEDED.
Ventilation:USE LOCAL EXHAUST VENTILATION NEAR THE SOURCE.
SHIELDS.
Other Protective Equipment:A SAFETY SHOWER & EYE WASH STATION SHOULD BE
WITHIN REASONABLE DISTANCE OF THE WORK AREA.
Supplemental Safety and Health
ITEM IS A TWO PART KIT. SEE MSDS SERIAL CLDZM.
================== Physical/Chemical Properties ==================
HCC:V7
Vapor Pres:2 MMHG
Vapor Density:3.8, AIR=1
Spec Gravity:1.2
Evaporation Rate & Reference:<01
Solubility in Water:SOLUBLE.
Appearance and Odor:LIQUID, MEDIUM VISCOSITY, AMBER COLOR, AMMONIA
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURES, OPEN FLAMES.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
POSSIBLE ORGANICS.
Conditions to Avoid Polymerization:HIGH TEMPERATURES, OPEN FLAMES.
EXOTHERMIC.
=================== Toxicological Information===================
Toxicological Information:TESTING HAS NOT BEEN PERFORMED ON THIS
===================== Ecological Information =====================
Ecological:NO SPECIFIC STUDIES HAVE BEEN CONDUCTED BY DEXTER ON THE
ECOTOXICITY OR ENVIRONMENTAL FATE OF THIS MATERIAL; HOWEVER,
COMMONLY AVAILABLE DATA ON THE ECOTOXICITY AND ENVIRONMENTAL FATE
OF CERTAIN OF TH E CONSTITUENTS OF THIS MATERIAL INDICATE THAT
UNCONTROLLED RELEASES TO SOIL, GROUNDWATER, OR SURFACE WATERS COULD
ENTAIL ACUTE AND/OR CHRONIC ECOLOGICAL EFFECTS, DEPENDING ON THE
QUANTITY & CONCENTRA TION OF SUCH RELEASES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL OF WASTE PROPERLY & IN ACCORDANCE WITH
LEGAL REQUIREMENTS IS THE RESPONSIBILITY OF THE OWNER/GENERATOR OF
THE WASTE, & MAY BE SUBJECT TO STATE &/OR LOCAL REGS, WHICH MAY
CHANGE FREQUENTLY. AC CORDINGLY, APPLICABLE LEGAL REQUIREMENTS
SHOULD BE CONFIRMED WITH ALL RELEVANT AUTHORITIES PRIOR TO
TREATMENT, STORAGE OR DISPOSAL OF WASTE.
=================== MSDS Transport Information ===================
Transport Information:DOT/IATA PROPER SHIPPING NAME: ENVIRONMENTALLY
HAZARDOUS SUBSTANCE, LIQUID, N.O.S., MARINE POLLUTANT, (DIBUTYL
PHTHALATE). DOT/IATA PACKING GROUP: III. DOT/IATA HAZARD CLASS OR
DIV: 9. DOT/IATA LABEL : CLASS 9. DOT/IATA PLACARD: CLASS 9.
DOT/IATA UN NUMBER: UN3082. PRODUCT REPORTABLE QTY (LBS): 10. ADR:
MARINE POLLUTANT. IMO (IMDG): REGULATED-REFER TO PAGE 9028.
SCHEDULE B: 3907.30.0000.
===================== Regulatory Information =====================
SARA Title III Information:COMPONENT PHENOL, 4,4'-(1-METH IS SUBJECT TO
THE FOLLOWING ENVIRONMENTAL LIST: 311/312 SARA SECT. 311/312.
COMPONENT OXIRANE, (BUTOXYMETH IS SUBJECT TO THE FOLLOWING
ENVIRONMENTAL LIST: 311/312 SARA S ECT. 311/312. COMPONENT
1,2-BENZENEDICARBOXY IS SUBJECT TO THE FOLLOWING ENVIRONMENTAL
LIST: 304 SEC. 302 AND CERCLA; 311/312 SARA SECT. 311/312., 313
SARA SECT. 313.
Federal Regulatory Information:OSHA: THIS PRODUCT IS HAZARDOUS UNDER
THE CRITERIA OF THE FEDERAL (USA) OSHA HAZARD COMMINUCATION
STANDARD 29 CFR 1910.1200. THERMAL PROCESSING AND DECOMPOSITION
FUMES FROM THIS PRODUCT MAY BE HAZARDO US. RCRA: THE PRODUCT USER
HAS THE RESPONSIBILITY AT DISPOSAL TIME TO DETERMINE IF THE
MATERIAL SHOULD BE CLASSIFIED AS A HAZARDOUS WASTE. THIS PRODUCT IS
CLASSIFIED AS RCRA NON-HAZARDOUS WASTE.
State Regulatory Information:THIS PRODUCT CONTAINS NO CHEMICALS KNOWN
TO THE STATE OF CALIFORNIA TO CAUSE CANCER AND/OR BIRTH DEFECTS OR
OTHER REPRODUCTIVE HARM.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:COATING, POLYURETHANE BROWN 30051 ID754201
Preparer's Name:W.A. ELLISON
CAGE:FO127
CAGE:FO127
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:1,6-DIISOCYANATOHEXANE (HEXAMETHYLENE DIISOCYANATE)
CAS:822-06-0
RTECS #:MO1740000
ACGIH TLV:0.005 PPM; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:VOL ORGANIC CMPD 2.2 LB/GL LESS WATER & NPRS* 264 G/L LESS
WATER VOC 3.1 LB/GAL SOLIDS 372 G/L SOLIDS CALCULATED
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:SWALLOWING:MAY BE FATAL IF SWALLOWED.
CAN CAUSE GASTROINTESTINAL/NAUSEA/VOMITING.ASPIRATION OF MATERIAL
INTO LUNG MAY CAUSE PNEUMONITIS.INHALATION:WARNING VAPOR AND SPRAY
MIST HARMFUL. MAY CAUSE LUNG DAMAGE.EYE & SKIN: IRRITATION, MAY
CAUSE SKIN SENSITIZATION.
Effects of Overexposure:EXPOSURE TO DIISOCYANATES MAY RESULT IN
RESPIRATORY SENSITIZATION. OVEREXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN AND NERVOUS SYSTEM DAMAGE. RESPIRATORY SENSITIVITY RESULTS IN
ASTHMA-LIKE SYMPTOMS ON S UBSEQUENT EXPOSURE AT CONCENTRATIONS EVEN
BELOW THE TLV.
Medical Cond Aggravated by Exposure:SEE ABOVE.
======================= First Aid Measures =======================
First Aid:SWALLOWING: DO NOT INDUCE VOMITING. GET MEDICAL ATTN
IMMEDIATELY. INHALATION:REMOVE TO FRESH AIR,KEEP WARM AND QUIET.GET
MED ATTN. EYE:WASH WITH WATER.GET MED ATTN.SKIN:WASH AFFECTED AREA
OBTAIN MED A TTN IF IRRITATION PERSISTS. NOTE TO PHYSICIAN: ANY
TREATMENT THAT MIGHT BE REQUIRED FOR OVEREXPOSURE SHOULD BE
DIRECTED AT THE CONTROL OF SYMPTOMS AND THE CLINICAL CONDITIONS.
===================== Fire Fighting Measures =====================
Flash Point:72F/22.22C
Extinguishing Media:CLASS B FIRE EXTINGUISHERS. POLYMER FOAM IS
PREFERRED FOR LARGE FIRES.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS. WATER
MAY BE USED TO COOL EXPOSED CONTAINERS TO PREVENT AUTO-IGNITION OR
EXPLOSION. FOG NOZZLES PREFERRED IF WATER USED
Unusual Fire/Explosion Hazard:OVEREXPOSURE TO DECOMPOSITION PRODUCTS
MAY CAUSE A HEALTH HAZARD. SYMPTOMS MAY NOT BE IMMEDIATELY
APPARENT. OBTAIN MEDICAL ATTENTION.
================== Accidental Release Measures ==================
Spill Release Procedures:USE NIOSH/MSHA APPROVED TC19C. ELIMINATE ALL
IGNITION SOURCES. DIKE WITH INERT MATERIAL. FOR RECOVERY OR
DISPOSAL USE METAL CONTAINERS. USE ONLY NON-SPARKING TOOLS.PREVENT
CONTAMINATION OF SEWERS,STRE AMS,GROUNDWATER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 95F. STORE LARGE
QUANTITIES IN COMPLIANCE WITH OSHA 29CFR1910.106.
Other Precautions:THIS PRODUCT SHOULD NOT BE USED BY PERSONS WHO HAVE
HAD CHRONIC BREATHING PROBLEMS OR REACTIONS TO ISOCYANATES.DO NOT
BREATH VAPOR SPRAY OR MIST. DO NOT GET ON SKIN, IN EYES OR ON
CLOTHING.WASH THOROU GHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR POSITIVE PRESSURE AIR SUPPLIED RESPIRATOR
(TC 19C NIOSH/MSHA) WHILE EXPOSED,IF NOT AVAILABLE USE A VAPOR
PARTICULATE RESPIRATOR. WEAR FOR THE WHOLE TIME WHILE MIXING,
SPRAYING AND UNTIL VAPORS AN D MISTS ARE GONE.
Ventilation:GENERAL DILUTION AND LOCAL EXHAUST VENTILATION IN
SUFFICIENT VOLUME AND PATTERN TO MAINTAIN CONCENTRATIONS.
Other Protective Equipment:AS REQUIRED TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
HAZARDOUS DECOMPOSITION PRODUCTS: THE REACTION OF ISOCYANATES WITH
WATER MAY PRODUCE HYDROGEN GAS WHICH MAY FORM FLAMMABLE OR
EXPLOSIVE MIXTURES WITH AIR.DO NOT WELD/BRAZE/CUT ON CONTAINER. DO
NOT REU SE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:260F
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:30
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS, OXIDIZING MATERIALS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT AND SOURCES OF
IGNITION.
Hazardous Decomposition Products:BURNING/WELDING/CUTTING WILL PRODUCE
SMOKE, CARBON MONOXIDE AND CARBON DIOXIDE. OXIDES OF NITROGEN MAY
BE GENERATED.
Conditions to Avoid Polymerization:KEEP AWAY FROM HEAT,SPARKS AND
FLAME.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE ONLY IN EPA FACILITY. CONTAMINATED
ABSORBANT DISPOSED IN A HAZARDOUS WASTE LANDFILL. DISPOSE ONLY IAW
FEDERAL/STATE/LOCAL REGULATIONS. RCRA CLASSIFICATION WOULD BE D001.
ENVIRONMENTAL HAZAR DS NONE KNOWN.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AGRI-PLEX FOR-X
Preparer's Name:HERMAN HAGEDORN
CAGE:RGBLA
CAGE:RGBLA
============= Composition/Information on Ingredients =============
Ingred Name:ZINC PHOSPHATE(-CITRATE)
Fraction by Wt: 0.5%
OSHA PEL:5 MG/M3 (ZN OXIDE)
ACGIH TLV:5 MG/M3 (ZN OXIDE)
Ingred Name:MANGANESE PHOSPHATE(-CITRATE)
Fraction by Wt: 0.5%
OSHA PEL:5 MG/M3 (MN)
ACGIH TLV:5 MG/M3 (MN)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:LIQUID MAY CAUSE SKIN IRRITATION.
INHALATION EXPOSURE NOT EXPECTED UNLESS USE PRODUCES A MIST.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF WATER FOR AT
LEAST 15 MINUTES. CALL MD IF IRRITATION EXPERIENCED. SKIN:WASH OFF
WITH FLOWING WATER USING SOAP. REMOVE CONTAMINATED CLOTHING AND
WASH BEFORE REUSE. INHAL:MISTS CAN BE IRRITATING. REMOVE TO FRESH
AIR. IF BREATHING DIFFICULT, GIVE OXYGEN. CALL MD.
===================== Fire Fighting Measures =====================
Flash Point:NON-COMBUSTIBLE
Extinguishing Media:DOES NOT BURN. USE MEDIA SUITABLE FOR SURROUNDING
FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:PREVENT PRODUCT FROM ENTERING DRINKING WATER
SUPPLIES OR STREAMS. DIKE AREA WITH SAND OR EARTH AND PUMP INTO
SALVAGE TANK. SMALLER QUANTITIES MAY BE TAKEN UP WITH INERT
ABSORBENT MATERIAL AND PACKAGED FOR DISPSAL ACCORDING TO LOCAL,
STATE & FED REGS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN PLASTIC TANK.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY NEEDED. IF MISTING OCCURS, USE
NIOSH/MSHA APPROVED RESPIRATOR TO ELIMINATE POSSIBLE INHALATION
EXPOSURE.
Ventilation:EXHAUST FAN TO CONTROL ANY MISTING.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
VAP PRESS:SAME AS WATER. VAP DENSITY:SAME AS WATER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:SUPP DATA
Vapor Density:SUPP DATA
pH:5.1
Evaporation Rate & Reference:SAME AS WATER
Solubility in Water:COMPLETELY MISCIBLE
Appearance and Odor:DARK GREEN LIQUID WITH NO CHARACTERISTIC ODOR
Percent Volatiles by Volume:20
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:DO NOT HEAT TO DRYNESS.
Hazardous Decomposition Products:SO*X IN ADDITION TO CARBON MONOXIDE
MAY BE RELEASED IF DRIED PRODUCT IS BURNED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL ACCORDING TO LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:UNIFLO 26
Preparer's Name:CHRISTENSEN LARSON
CAGE:OAN54
CAGE:OAN54
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM METASILICATE, (SODIUM SILICATE & WATER GLASS)
CAS:6834-92-0
RTECS #:VV9275000
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 ORAL (RAT): 800 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: COUGHING, SNEEZING & UPPER
RESPIRATORY TRACT IRRITATION. SKIN: IRRITANT. BURNS. EYE: TISSUE
DESTRUCTION & PERMANENT DAMAGE. INGESTION: CORRISIVE TO MUCOUS
MEMBRANES OF THE MOUTH, THROAT, E SOPHAGUS & STOMACH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: COUGHING, SNEEZING, UPPER
RESPIRATORY TRACT IRRITATION & LUNG TISSUE DAMAGE. SKIN: IRRITANT,
SEVERE BURNS. EYE: TISSUE DESTRUCTION, PERMANENT CORNEAL DAMAGE.
INGESTION: CORROSIVE TO MUCOUS MEMBRANES OF THE RESPIRATORY TRACT,
MOUTH, THROAT, ESOPHAGUS & STOMACH.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER 15 MIN. SEEK MED ATTN. SKIN: FLUSH W/COOL
WATER & GET MED ATTN. REMOVE/LAUNDER CONTAMINATED CLOTHING/SHOES
BEFORE REUSE. INHALATION: REMOVE TO FRESH AIR. IF BREATHING
STOPS/DIFFICU LT, GIVE MOUTH-TO-MOUTH RESUSCITATION/OXYGEN. GET MED
ATTN. INGESTION: NEVER GIVE ANYTHING TO UNCONSCIOUS PERSON. DON'T
INDUCE VOMITING. IF VOMITING, KEEP AIRWAY CLEAR. GIVE MILK/WATER.
SEEK MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NONFLAMMABLE
Upper Limits:NONFLAMMABLE
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CO2, FOAM.
Fire Fighting Procedures:PRESSURE-DEMAND, SELF-CONTAINED BREATHING
APPARATUS SHOULD BE WORN.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN LIQUIDS & PREVENT DISCHARGES TO
STREAMS OR SEWERS SYSTEMS. LEAKS SHOULD BE STOPPED AFTER
CONTAINMENT, SHOULD BE SHOVELED UP TO BE REMOVED BY VACUUM TRUK TO
A CHEMICAL WASTE AREA. FLUSH SPILL W /WATER. COVER W/SODIUM
BIOCARBONATE.
Neutralizing Agent:DILUTE ACID
======================Handling and Storage ======================
Handling and Storage Precautions:WEAR CHEMICAL SPLASH CLOTHES/FACE
PROTECTION WHEN HANDLING/MAKING SOLUTIONS. WASH AFTER HANDLING.
KEEP AWAY FROM ACIDS & KEEP CONTAINER CLOSED.
Other Precautions:ALWAYS ADD SLOWLY TO LIQUID SURFACE TO MAKE SOLUTION,
&& STIR CONSTANTLY TO DISSIPATE HEAT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH/MSHA APPROVED RESPIRATOR
Ventilation:LOCAL EXHAUST
Other Protective Equipment:EMERGENCY SHOWER, EYEWASH
Work Hygienic Practices:WASH SOILED CLOTHING & DRY BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:162F
pH:12.4%
Solubility in Water:28%
Appearance and Odor:WHITE CRYSTALLINE SOLID, NO ODOR
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDIC MATERIALS.
Stability Condition to Avoid:HEAT
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:PROPER AGENCIES SHOULD BE CONTACTED TO ASSURE
PROPER ACTION BEING TAKEN. CLEAN-UP ACTION SHOULD BE CAREFULLY
PLANNED & EXECUTED. SHIPMENT, STORAGE &/OR DISPOSAL OF WATE
MATERIALS ARE REGULATED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EDTA 0.1428M SOLUTION; CAT.NO. 14960
CAGE:91224
CAGE:91224
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENEDIAMINETETRAACETIC ACID,TETRASODIUM SALT, DIHYDRATE
CAS:64-02-8
RTECS #:AH5075000
Fraction by Wt: <10%
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
Ingred Name:OTHER COMPONENT (NOT SPECIFIED)
OSHA PEL:N/R (BY MFR)
ACGIH TLV:N/R (BY MFR)
Ingred Name:DEMINERALIZED WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: >90%
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K MFR:MODERATELY TOXIC
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATING OR CORROSIVE TO EYES, SKIN,
OR RESPIRATORY TRACT
Effects of Overexposure:IRRITATING OR CORROSIVE TO EYES, SKIN,
RESPIRATORY TRACT. HYPOCALCEMIA
Medical Cond Aggravated by Exposure:NONE LISTED
======================= First Aid Measures =======================
First Aid:INHAL:RMV TO FRESH AIR. IF NOT BRTHNG GIVE CPR; IF BRTHNG
DIFF GIVE OXYGEN. EYE:IMMED FLUSH W/PLENTY OF WATER. SKIN:WASH
W/SOAP & WATER. RMV CONTAM CLTHG & SHOES. INGEST:DO NOT INDUCE
VOMIT. NOTHG BY MOUTH IF UNCONSC. GET MEDICAL ATTN.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:EXTINGUISH WITH AGENT SUITABLE FOR SURROUNDING FIRE
Fire Fighting Procedures:USE SCBA
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER SPILL IN BEAKER, NEUTRALIZE WITH
HYDROCHLORIC ACID.
Neutralizing Agent:HYDROCHLORIC ACID
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED,LOW
FIRE RISK AREA. PROTECT FROM PHYSICAL DAMAGE.KEEP CONTAINERS
CLOSED. MAINTAIN STANDARD HYGIENE FOR CHEM HANDLING
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:MFR: NONE HMIS:SAFETY SHOWER AND EYE WASH
Work Hygienic Practices:USE NORMAL CHEMICAL HYGIENE PRACTICES
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F/100C
Spec Gravity:1.030
Appearance and Odor:CLEAR LIGHT YELLOW LIQUID, NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE STATED BY MFR
Stability Condition to Avoid:NONE STATED BY MFR
Hazardous Decomposition Products:NONE STATED BY MFR. HMIS:CARBON
DIOXIDE,CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE TO DRAIN I/A/W FEDERAL,STATE,LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-P-63460D
CAGE:0DHB8
CAGE:0DHB8
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM SOLVENTS
Fraction by Wt: 20%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ORGANO BARIUM
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:BARIUM (SARA III)
CAS:7440-39-3
RTECS #:CQ8370000
Fraction by Wt: 1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.5 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:WARNING--SEVERE EYE IRRITANT, MODERATE
SKIN AND RESPIRATORY TRACT IRRITANT. ASPIRATION HAZARD IF
SWALLOWED, CAN ENTER LUNGS AND CAUSE DAMAGE.
Effects of Overexposure:CONTAINS A PETROLEUM SOLVENT WHICH MAY ON
OVEREXPOSURE CAUSE HEADACHE, DIZZINESS, DROWSINESS, UNCONSCIOUSNESS
AND OTHER NERVOUS SYSTEM EFFECTS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:CONTACT-WASH SKIN WITH SOAP & WATER. FLUSH EYES WITH PLENTY
OF WATER FOR 15 MINUTES. CALL A PHYSICIAN IF IRRITATION DEVELOPS.
INHALATION-REMOVE VICTIM TO FRESH AIR & GIVE CPR OR OXYGEN IF
NEEDED. CALL A PHYSICIAN. INGESTION-DO NOT INDUCE VOMITING. HAVE
VICTIM DRINK 8-10 OUNCES OF WATER TO DILUTE MATERIAL IN STOMACH.
CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:165F,74C
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE OR WATER FOG.
Fire Fighting Procedures:BURNING WILL PRODUCE TOXIC FUMES INCLUDING
CARBON MONOXIDE AND CARBON DIOXIDE. WEAR SELF-CONTAINED BREATHING
APPARATUS & FULL TURN-OUT GEAR TO FIGHT FIRE.
Unusual Fire/Explosion Hazard:EXPOSURE TO HEAT BUILDS UP PRESSURE IN
CLOSED CONTAINERS. COOL WITH WATER SPRAY. AVOID SPREADING LIQUID
AND FIRE BY WATER FLOODING.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION AND VENTILATE AREA.
COVER WITH INERT, ABSORBENT MATERIAL AND REMOVE TO DISPOSAL
CONTAINER. OBEY ALL REVELANT FEDERAL, STATE AND LOCAL LAWS AND
REGULATIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT AND FLAMES. KEEP
CONTAINER CLOSED. USE WITH ADEQUATE VENTILATION.
Other Precautions:WARNING--AVOID CONTACT WITH EYES, SKIN OR CLOTHING.
AVOID BREATHING VAPOR OR MIST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSED, USE APPROPIATE NIOSH-APPROVED
RESPIRATORY PROTECTIVE EQUIPMENT.
Ventilation:LOCAL EXHAUST AND MECHANICAL: RECOMMENDED.
Other Protective Equipment:EYE WASH FOUNTAIN, SAFETY SHOWER. WASH
CONTAMINATED CLOTHING BEFORE REUSE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:>400F,>204C
Melt/Freeze Pt:M.P/F.P Text:-74F,-59C
Vapor Density:>AIR
Spec Gravity:0.86
Evaporation Rate & Reference:SLOWER THAN BU/AC
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT YELLOW TO BROWN LIQUID, MILD SOLVENT ODOR.
Percent Volatiles by Volume:42.5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:OBEY RELEVANT LOCAL, STATE AND FEDERAL LAWS AND
REGULATIONS. DO NOT CONTAMINATE LAKES, STREAMS, PONDS OR
UNDERGROUND WATER SUPPLY.
======================================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ELECTRO-WASH C2 (LIQUID), ES7155
CAGE:2M589
CAGE:21267
CAGE:2M589
============= Composition/Information on Ingredients =============
Ingred Name:CHEMICAL MIXTURE; (CIROZANE). LD50: (ORAL, RAT) >5 G/KG.
Fraction by Wt: 85-90%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CYCLOHEXANE, METHYL-; (METHYLCYCLOHEXANE).LD50: (ORAL,
MOUSE) >2250 MG/KG.
CAS:108-87-2
RTECS #:GV6125000
Fraction by Wt: 1-10%
OSHA PEL:500 PPM
ACGIH TLV:400 PPM
Ingred Name:METHANOL; (CARBINOL) (SARA 313) (CERCLA). LD50: (ORAL,
RAT) 5628 MG/KG.
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 1-5%
OSHA PEL:200 PPM, S
ACGIH TLV:200 PPM; 250 STEL, S
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SPILL PROC: RUNOFF CAN CAUSE ENVIRONMENTAL DAMAGE. U.S.
REGS REQUIRE REPORTING SPILLS OF THIS MATL THAT COULD (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: REACH ANY SURFACE WATERS. TOLL FREE NUMBER FOR U.S.
COAST GUARD NRC IS 1-800-424-8802.
RTECS #:9999999ZZ
Ingred Name:HNDLG/STOR PRECS: CONTAINER. STORE IN A COOL, DRY PLACE
AWAY FROM HEAT, SPARKS & FLAME. KEEP CONTAINER CLOSED (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: WHEN NOT IN USE. DO NOT STORE IN DIRECT SUNLIGHT.
KEEP OUT OF REACH OF CHILDREN. FOR INDUSTRIAL USE ONLY.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: LIQUID, AEROSOLS AND
VAPORS OF THIS PRODUCT MAY BE IRRITATING AND CAN CAUSE PAIN,
TEARING, REDDENING AND SWELLING ACCOMPANIED BY STINGING SENSATION.
SKIN: PROLONGED CONTACT CAN CAUSE SKIN IRRITATION. INGESTION: MAY
BE HARMFUL IF SWALLOWED. SWALLOWING THIS MATERIAL MAY RESULT IN
NAUSEA, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: VOMITING & WEAKNESS FOLLOWED BY CNS
DEPRESSION. INHALATION: CAN BE HARMFUL IF INHALED. HIGH
CONCENTRATIONS OF VAPORS IN IMMEDIATE AREA CAN CAUSE DIZZINESS,
NAUSEA AND VOMITING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:IMMED FLUSH W/PLENTY OF WATER. AFTER INITIAL FLUSHING,
REMOVE ANY CNTCT LENSES & CONTINUE FLUSHING FOR AT LST 15 MIN. HAVE
EYES EXAMINED BY MED PERS IF IRRIT DEVELOPS/PERSISTS. SKIN:WASH
SKIN W/S OAP & WATER. REMOVE CONTAM CLTHG. GET MED ATTN IF IRRIT
DEVELOPS/PERSISTS. WASH CLTHG BEFORE REUSE. INGEST:IF SWALLOWED, DO
NOT INDUCE VOMIT. IF CONSCIOUS, GIVE 2 GLASSES OF WATER. NEVER GIVE
(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE TO BOILING
Extinguishing Media:USE WATER SPRAY OR FOG, CARBON DIOXIDE, DRY
CHEMICAL OR WATER STREAM WHEN FIGHTING FIRES INVOLING THIS
MATERIAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:SHUT OFF LEAK IF POSS & SAFE TO DO SO. ABSORB
SPILL W/INERT MATL (EG DRY SAND OR EARTH), THEN PLACE IN A CHEMICAL
WASTE CNTNR FOR PROPER DISPOSAL. DO NOT FLUSH TO SEWER. AVOID
RUNOFF INTO STORM SEWERS & DITCHES WHICH LEAD TO WATERWAYS. WATER
(ING 4)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PRLNGD/RTPD CONTACT W/EYES, SKIN
& CLTHG. WASH HANDS BEFORE EATING. USE W/ADEQ VENT. AVOID BRTHG
PROD VAP OR MIST. DO NOT REUSE THIS (ING 6)
Other Precautions:DO NOT PUNCTURE OR INCINERATE CONTAINERS. NORMAL
VENTILATION FOR STANDARD MANUFACTURING PRACTICES IS USUALLY
ADEQUATE. LOCAL EXHAUST SHOULD BE USED WHEN LARGE AMOUNTS ARE
RELEASED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT TO CONTROL
AIRBORNE LEVELS.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
CNDTNS TO AVOID: SURFS OR OTHER IGNIT SOURCES. MATL TO AVOID: CAUSTIC
SODA, CAUSTIC POTASH OR OXIDIZERS. EFTS OF OVEREXP: ANYTHING BY
MOUTH TO UNCON PERSON. KEEP HEAD BELOW KNEES TO MINIMIZE CHANCE OF
ASPIRATING MATL INTO LUNGS. GET MED ATTN IMMED. INHAL: REMOVE TO
FRESH AIR. IF BRTHG DFCLT, GIVE OXYGEN. GET MED ATTN.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:30.0F,-1.1C
Vapor Pres:220 @ 70F
Spec Gravity:1.53 (H*2O=1)
Evaporation Rate & Reference:>1 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID; ETHEREAL ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
DO NOT MIX WITH CHEMICALLY ACTIVE METALS SUCH AS POTASSIUM, MAGNESIUM
ZINC & POWDERED ALUMINUM, STRONG BASE, (SUPDAT)
Stability Condition to Avoid:STRONG OXIDIZERS, ELEVATED TEMPS. KEEP
AWAY FROM ELEVATED TEMPS. DO NOT SPRAY NEAR OPEN FLAMES, RED HOT
(SUPDAT)
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY RELEASE
CARBON MONOXIDE, CARBON DIOXIDE, HYDROGEN CHLORIDE AND HYDROGEN
FLUORIDE.
Conditions to Avoid Polymerization:FINALLY DIVIDED ACTIVE METALS,
ALKALI AND ALKALINE EARTH METALS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE
AND LOCAL REGULATIONS. WATER RUNOFF CAN CAUSE ENVIRONMENTAL DAMAGE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FORMALDEHYDE
CAGE:4A444
CAGE:36842
CAGE:4A444
============= Composition/Information on Ingredients =============
Ingred Name:FORMALDEHYDE
CAS:50-00-0
RTECS #:LP8925000
Minumum % Wt:30.
Maxumum % Wt:40.
Other REC Limits:0.016 PPM, C 0.1 PPM
ACGIH STEL:0.3 PPM, .37 MG/M3 C
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:METHANOL
CAS:67-56-1
RTECS #:PC1400000
Minumum % Wt:5.
Maxumum % Wt:15.
ACGIH TLV:200 PPM, 262 MG/M3,S
ACGIH STEL:250 PPM, 328 MG/M3,S
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: BALANCE
===================== Hazards Identification =====================
LD50 LC50 Mixture:FORMALDEHYDE ORAL LD50: 100 MG/KG (RAT)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:EFFECTS OF ACUTE EXPOSURE: MAY BE
FATAL BY INGESTION, INHALATION OR SKIN ABSOPTION. CORROSIVE. SEVERE
LACHRYMATOR. 100 PPM IS IMMEDIATELY DANGEROUS TO LIFE OR HEALTH.
TARGET ORGANS: CENTRAL NERVOUS SY STEM, LIVER, KIDNEYS, SPLEEN,
EYES, SKIN, GASTROINTESTINAL SYSTEM, RESPIRATORY SYSTEM, LUNGS,
REPRODUCTIVE SYSTEM, PERIPHERAL NERVOUS SYSTEM, PANCREAS. EYE:
VAPORS AND MIST CAUSES TEARING AND SEVERE IRRITATION. LIQUID
CAUSES SEVERE BURNS. CAN RESULT IN CORNEAL DAMAGE OR BLINDNESS.
IRRITATION: EYE-RABBIT 750 UG/24H SEVERE. SKIN: CONTACT WITH LIQUID
CAUSES DRYING, SCALING AND CRACKING. PROLONGED AN D (SIGNS AND
SYMPTOMS OF OVEREXPOSURE)
Explanation of Carcinogenicity:FORMALDEHYDE: IARC, GROUP 2A, VOL. 62,
P. 217, 1995. NTP REASONABLY ANTICIPATED CARCINOGEN, NTP NINTH
REPORT ON CARCINOGENS, 1998. OSHA REGULATED 29 CFR 1910.1048.
Effects of Overexposure:HEALTH HAZARDS ACUTE AND CHRONIC
(CONT):-REPEATED CONTACT CAUSES HARDENING OR TANNING EFFECT. MAY
CAUSE ALLERGIC DERMATITIS. LIQUID CAN BE ABSORBED IN TOXIC AMOUNTS
THROUGH INTACT SKIN (MASSIVE SKIN C ONTACT CAN CAUSE VISUAL
IMPAIRMENT AND DEATH). IRRITATION: SKIN-RABBIT 2MG/24H SEVERE.
INHALATION: HIGHLY TOXIC. VAPORS AND MISTS ARE EXTREMELY IRRITATING
TO THE NOSE, THROAT, LUNGS, MUCOUS MEMBRANES. BRONCHITIS,
BRONCHOPNEUMONIA, PULMONARY EDEMA AND CHEMICAL PNEUMONITIS MAY
OCCUR. PROLONGED EXPOSURE MAY RESULT IN MORE SEVERE IRRITATION AND
TISSUE DAMAGE. METHANOL CAN CAUSE SEVERE CENTRAL NERVOUS SYSTEM
(ECOLOGICAL INFO)
======================= First Aid Measures =======================
First Aid:EYE CONTACT: IMMEDIATE FIRST AID IS NEEDED TO PREVENT EYE
DAMAGE. IMMEDIATELY FLUSH EYES WITH COPIOUS QUANTITIES OF WATER FOR
AT LEAST 20 MINUTES HOLDING LIDS APART TO ENSURE FLUSHING OF ENTIRE
SURFAC E. SEEK IMMEDIATE MEDICAL ATTENTION. SKIN: IMMEDIATE FIRST
AID IS NEEDED TO PREVENT SKIN DAMAGE. IMMEDIATELY FLUSH SKIN WITH
PLENTY OF WATER FOR AT LEAST 20 MINUTES WHILE REMOVING CONTAMINATED
CLOTHIN G AND SHOES. SEEK IMMEDIATE MEDICAL ATTENTION. WASH
CONTAMINATED CLOTHING BEFORE REUSE. INHALATION: REMOVE PATIENT TO
FRESH AIR. ADMINISTER APPROVED OXYGEN SUPPLY IF BREATHING
DIFFICULT. ADMINISTER AR TIFICIAL RESPIRATION OR CPR (SARA III)
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:=50.C, 122.F
50-78C
Autoignition Temp:=299.C, 570.2F
Lower Limits:7%
Upper Limits:73%
Extinguishing Media:USE DRY CHEMCIAL, CARBON DIOXIDE, ALCOHOL-RESISTANT
FOAM OR WATER SPRAY. NOTE: UPPER AND LOWER FLAMMABLE LIMITS AND
AUTOIGNITION TEMPERATURE ARE FOR FORMALDEHYDE GAS.
Fire Fighting Procedures:WEAR ADEQUATE PERSONAL PROTECTION TO PREVENT
CONTACT WITH MATERIAL OR ITS COMBUSTION PRODUCTS. SELF CONTAINED
BREATHING APPARATUS (NIOSH APPROVED - ) WITH A FULL FACEPIECE
OPERATED IN A PRESSURE D EMAND OR OTHER POSITIVE PRESSURE MODE.
COOL CONTAINING VESSELS WITH FLOODING QTYS OF WATER UNTIL WELL
AFTER FIRE IS OUT.
Unusual Fire/Explosion Hazard:COMBUSTIBLE. VAPOR MAY TRAVEL
CONSIDERABLE DISTANCE TO SOURCE OF IGNITION & FLASHBACK, ELIMINATE
SOURCES OF IGNITION. VAPOR FORMS EXPLOSIVE MIXTURE W/ AIR.
CONTAINER EXPLOSION MAY OCCUR UNDER FIRE CON DITIONS OR WHEN
HEATED. CONT WITH OXIDIZERS MAY CAUSE FIRE AND/OR EXPLOSION. EMITS
TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:STAY UPWIND: KEEP OUT OF LOW AREAS. EVACUATE &
VENTILATE AREA. ELIMINATE ALL SOURCES OF IGNITION.DYKE AREA W/
SAND OR NATURAL BARRIER. ABSORB ON SAND OR VERMICULITE & PUT
SPILLED MATERIAL IN AN APPR OP WASTE DISPOSAL. USE NON-SPARKING
TOOLS. WASH SPILL SITE AFTER MATERIAL PICKUP COMPLETE. DO NOT EMPTY
INTO DRAINS. DO NOT TOUCH SPILLED MATERIAL. RUNOFF TO SEWER MAY
CREATE FIRE OR EXPLOSION HAZARD.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL PLACE AWAY FROM HEATED
AREAS, SPARKS AND FLAME. STORE IN A WELL-VENTILATED AREA. STORE
AWAY FROM INCOMPATIBLE MATERIALS. DO NOT ADD ANY OTHER MATERIAL TO
THE CONTAINER. DO NOT WASH DOWN THE DRAIN. DO NOT BREATHE GAS /
FUMES / VAPOR / SPRAY. IN CASE OF INSUFFICIENT (OTHER PRECAUTIONS)
Other Precautions:HANDLING AND STORAGE PRECAUTIONS (CONT): VENTILATION,
WEAR SUITABLE RESPIRATORY EQUIPMENT. KEEP CONTAINER TIGHTLY CLOSED.
MANIPULATE UNDER AN ADEQUATE FUME HOOD. TAKE PRECAUTIONARY MEASURES
AGAINST EL ECTROSTATIC DISCHARGES. GROUND THE CONTAINER WHILE
DISPENSING. GROUND ALL EQUIPMENT CONTAINING MATER IAL. (FEDERAL
REGS)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A (NIOSH-APPROVED) RESPIRATOR IS ADVISED IN THE
ABSENCE OF PROPER ENVIRINMENTAL CONTROLS. IF MORE THAN TLV, DO NOT
BREATHE VAPOR. WEAR (NIOSH APPROVED - ) SELF-CONTAINED BREATHING
APPARATUS. E XPOSURE LIMITS (ALSO SEE INGREDIENTS SECTION - ):
FORMALDEHYDE: NIOSH REL TO FORMALDEHYDE-AIR: 8H CA TWA 0.016 PPM;
CEILING LIMIT 0.1 PPM / 15M.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD TO KEEP AIRBORNE LEVELS
BELOW REC EXPOSURE LIMITS. USE EXPLOSION-PROOF VENTILATION
EQUIPMENT. DO NOT USE IN UNVENTILATED SPACES
.
Other Protective Equipment:PROTECTIVE CLOTHING: IMPERVIOUS PVC, NITRILE
OR NEOPRENE APRON, COVERALLS AND/OR OTHER RESISTANT PROTECTIVE
CLOTHING. SUFFICIENT TO PROTECT SKIN. MAKE EYE BATH AND EMERGENCY
SHOWER AVAILABLE.
Work Hygienic Practices:HAVE AVAILABLE AND USE AS APPROPRIATE: FACE
SHIELDS, RUBBER SUITS, AND BOOTS. DO NOT WEAR CONTACT LENSES.
ENSURE THAT EYEWASH STATION AND SAFETY SHOWER IS PROXIMAL TO THE
WORK-STATION LOCATION.
Supplemental Safety and Health
FIRE DEGRADATION PRODUCTS: OXIDES OF CARBON (CO, CO2). PROTECTIVE
CLOTHING IN CASE OF SPILL & LEAK: WEAR SELF-CONTAINED BREATHING
APPARATUS (ANSI APPROVED - ), RUBBER BOOTS & HEAVY RUBBER GLOV ES.
FULL SUIT. PHYSICAL/CHEMICAL PROPERTIES (CONT): ODOR THRESHOLD:
0.8-1 PPM.WATER/OIL DIST COEFF: NOT AVAILABLE
================== Physical/Chemical Properties ==================
Boiling Pt:=90.C, 194.F
B.P. Text:90-100C
Melt/Freeze Pt:M.P/F.P Text:INSOLUBLE POLYMER FORMS
Vapor Pres:40 MMHG @39C (APPROX)
Vapor Density:0.62-1.16
Spec Gravity:1.08-1.0975 (WATER=1)
pH:2.8 - 4.0 (25C)
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID WITH STRONG FORMALDEHYDE
ODOR.
Percent Volatiles by Volume:100% (V/V)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY REACT VIOLENTLY WITH: ACIDS, ALKALIS, ANHYDRIDES, ISOCYANTAES,
UREA, PHENOL, OXIDIZING AGENTS, OXIDES, ORGANIC OXIDES, REDUCING
AGENTS, AMMONIA, ANILINE, MAGNESIUM CARBONATE, PERFORMIC ACID,
ALKALI METALS, AMINES, (STAB
Stability Condition to Avoid:HEAT, SPARKS AND FLAME, TEMPERATURES BELOW
20C. MATERIALS TO AVOID (CONT): HYDROGEN PEROXIDE, NITROMETHANE,
NITROGEN DIOXIDE, PERCHLORIC ACID, (CONDITIONS TO AVOID
POLYMERIZATION)
Hazardous Decomposition Products:NOT AVAILABLE. REACTION PRODUCTS:
REACTION WITH HYDROCHLORIC ACID MAY FORM BIS-CHLOROMETHYL ETHER, A
CONFIRMED HUMAN CARCINOGEN ACCORDING TO ACGIH AND CARCINOGENIC TO
HUMANS ACCORDING TO IARC.
Conditions to Avoid Polymerization:WILL NOT OCCUR. STABILITY CONDS
TO AVOID (CONT): BASES, MONOMERS, WATER REACTIVE MATERIALS,
MAGNESIUM CARBONATE HYDROXIDE.
=================== Toxicological Information===================
Toxicological Information:TOXICITY VALUES OF THE HAZARDOUS INGREDIENTS:
FORMALDEHYDE: ORAL (LD50): ACUTE: 100 MG/KG (RAT), 42 MG/KG
(MOUSE), 260 MG/KG (GUINEA PIG). ORAL (LDLO): ACUTE: 108 MG/KG
(WOMAN). DERMAL (LD50): ACUTE: 270 UL/KG (RABBIT). VAPOR (LC50):
ACUTE: 203 MG/M3 (RAT), 92 MG/M3 (MAMMAL), 400 MG/M3 (MOUSE) (2
HOUR(S)). METHANOL: ORAL (LD50): ACUTE: 5628 MG/KG (RAT), 7300
MG/KG (MOUSE), 14200 MG/KG (RABBIT). D ERMAL (LD50): ACUTE: 15800
MG/KG (RABBIT). VAPOR (LC50): ACUTE: 64000 PPM (RAT) (4 HOUR(S)).
===================== Ecological Information =====================
Ecological:N/P. SIGNS AND SYMPTOMS OF OVEREXPOSURE (CONT):
DEPRESSION (SIGNS AND SYMPTOMS MAY INCLUDE HEADACHE, DIZZINESS,
NAUSEA, VOMITING, DROWSINESS AND INCOORDINATION), COUGHING, CHEST
PAIN, AND DYSPNEA.CAN AFFECT OPTIC NERVE RESULTING IN BLINDNESS.
INGESTION: HIGHLY TOXIC. VAPORS, MISTS, AND LIQUID ARE EXTREMELY
IRRITATING TO THE MOUTH AND THROAT AND STOMACH. SWALLOWING THE
LIQUID INFLAMES TISSUES, CAUSES SEVERE ABDOMINAL PAIN, NAUSEA,
VOMITING, HEATURIA, PROTEINURIA, ANURIA, ACIDOSIS AND POSSIBLE LOSS
OF CONSCIOUSNESS. METHANOL CAN AFFECT OPTIC NERVE, RESULTING IN
BLINDNESS.EFFECTS OF CHRONI C OVEREXPOSURE: RATS (TRANSPORT INFO)
==================== Disposal Considerations ====================
Waste Disposal Methods:ACCORDING TO ALL APPLICABLE REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:TDG ROAD / RAIL: TDG CLASS: 3 8 9.2. PIN:
UN1198. PG: III. ECOLOGICAL INFO (CONT): CHRONICALLY EXPOSED TO
14 PPM FORMALDEHYDE CONTRACTED NASAL CANCERS. BASED ON ANIMAL DATA
AND LIMITED EPIDEMIOLO GICAL EVIDENCE, NTP, IARC, AND OSHA
HAVELISTED FORMALDEHYDE AS A PROBABLE HUMAN CARCINOGEN. POSSIBLE
REPRODUCTIVE DISORDERS FROM PROLONGED EXPOSURE (EMBRYOTOXIC).
MUTAGEN. PASSES THROUGH THE PLACENTAL BARRIER IN ANIMAL. MAY CAUSE
SENSITIZATION BY INHALATION (ASTHMA) & SKIN CONTACT (DERMATITIS).
CAUSES CNS DEPRESSION. MAY CAUSE DAMAGE TO THE CNS, RESPIRATORY
SYSTEM, LUNGS, EYES, SKIN, GASTROINTESTI NAL TRACT, LIVER, SPLEEN
AND KIDNEYS.
===================== Regulatory Information =====================
SARA Title III Information:N/P. FIRST AID (CONT): IF BREATHING HAS
CEASED. SEEK IMMEDIATE MEDICAL ATTENTION. INGESTION: IF CONSCIOUS,
WASH OUT MOUTH WITH WATER. HAVE CONSCIOUS PERSON DRINK SEVERAL
GLASSES OF WATER TO DILUT E. SEEK IMMEDIATE MEDICAL ATTENTION.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS OR CONVULSING
PERSON.
Federal Regulatory Information:WHMIS CLASS: B-3 E D-1A D-2A. OTHER
PRECAUTIONS (CONT): USE ONLY EXPLOSION PROOF EQUIPMENT. USE
NON-SPARKING TOOLS. WATCH FOR ACCUMULATION IN LOW CONFINED AREAS.
DO NOT USE PRESSURE TO DISPENSE. STORAGE TEMPERATURE DEPENDS ON
METHANOL CONTENT AND SHOULD BE CONTROLLED TO AVOID PRECIPITATION OR
VAPORIZATION. LOW TEMPERATURE STORAGE RESULTS IN FORMATION OF
PARAFORMALDEHYDE, WHILE HIGH TEMPERATUR E STORAGE PRODUCES FORMIC
ACID. KEEP AWAY FROM DIRECT SUNLIGHT OR STRONG INCANDESCENT LIGHT.
EMPTY C ONTAINERS MAY CONTAIN HAZARDOUS RESIDUE. HANDLE AND OPEN
CONTAINER WITH CARE. TAKE OFF IMMEDIATELY ALL CONTAMINATED
CLOTHING. (STATE REGS)
State Regulatory Information:N/P. FEDERAL REGS (CONT):THIS PRODUCT
MUST BE MANIPULATED BY QUALIFIED PERSONNEL. DO NOT GET IN EYES, ON
SKIN, OR ON CLOTHING. WASH WELL AFTER USE. IN ACCORDANCE WITH GOOD
STORAGE AND HANDLING PR ACTICES. DO NOT ALLOW SMOKING AND FOOD
CONSUMPTION WHILE HANDLING. OTHER INFO (CONT): USE
NON-SPARKING TOOLS. HANDLE AND OPEN CONTAINER WITH CARE. CONTAINER
SHOULD BE OPENED ONLY BY A TECHNICALLY QUALIFIED PERSON. HARMFUL
TO AQUATIC LIFE AT LOW CONCENTRATIONS. CAN BE DANGEROUS IF ALLOWED
TO ENT ER DRINKING WATER INTAKES. DO NOT CONTAMINATE DOMESTIC OR
IRRIGATION WATER SUPPLIES, LAKES, STREAMS, PONDS, OR RIVERS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PRIDE BLACK
CAGE:0YLF6
CAGE:0YLF6
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS MATERIAL
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: IRRITATION
FROM PROLONGED CONTACT. INHALATION: IRRITATION FROM PROLONGED
EXPOSURE WITH LITTLE VENTILATION. INGESTION: LARGE QUANTITIES
UPSETTING TO GASTRO INTESTINAL TRACT.
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER. SKIN: WASH WITH SOAP AND WATER.
INHALATION: REMOVE TO FRESH AIR. INGESTION: GIVE 2 GLASSES WATER.
DO NOT INDUCE VOMITING. SEEK MEDICAL ATTENTION IF SYMPTOMS ARE NOT
ALLEVIATED.
===================== Fire Fighting Measures =====================
Flash Point:200F,93C
Extinguishing Media:WATERSPRAY, CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:FIREFIGHTERS WEAR FULL FACE UNITS.
Unusual Fire/Explosion Hazard:UPON BURNING, TOXIC GASES MAY BE
RELEASED.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE SOURCES OF IGNITION. SMALL: COLLECT
ON ABSORBENT. LARGE: CONTAIN, REUSE OR ABSORB. FLUSH AWAY RESIDUE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED. KEEP AWAY FROM
FIRE & HEAT OR FREEZING CONDITIONS. USE WITH ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NEEDED IF VENTILATION IS ADEQUATE.
Work Hygienic Practices:WASH AFTER EACH USE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:1 MM
Spec Gravity:1.00 (WATER=1)
Solubility in Water:DISPERSABLE
Appearance and Odor:LIQUID BLACK; MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:THERMAL DECOMPOSTION MAY PRODUCE CO,
CO2, AMMONIA, TOXIC VAPORS.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN ACCORDANCE WITH FEDERAL, STATE,
AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: EASY-FLO 45
Cage: 6A753
=======================================================
Contractor Summary
=======================================================
Cage: 6A753
=======================================================
Ingredients
=======================================================
ORGANS & BRAIN. CADMIUM HAS ALSO CAUSED
-----------------------------
-----------------------------
MUSCULOSKELETAL SYSTEM.
-----------------------------
-----------------------------
CUTTING" (AMERICAN WELDING SOCIETY, MIAMI, FL 33135).
-----------------------------
-----------------------------
(SHADE #3 OR #4) ARE RECOMMENDED.
-----------------------------
-----------------------------
Cas: 7440-43-9
RTECS #: EU9800000
% Wt: 5-24
OSHA PEL: 0.05 MG/M3 DUST&FUME
ACGIH TLV: 0.05 MG/M3 DUST
EPA Rpt Qty: 10 LBS
DOT Rpt Qty: 10 LBS
------------------------------
Cas: 7440-50-8
RTECS #: GL5325000
% Wt: 15-45
OSHA PEL: 0.1MG/M3 FUME;1 DUST
ACGIH TLV: 0.2MG/M3 FUME;1 DUST
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 7440-22-4
RTECS #: VW3500000
% Wt: 20-50
OSHA PEL: 0.01 MG/M3
ACGIH TLV: 0.1 MG/M3
EPA Rpt Qty: 1 LB
DOT Rpt Qty: 1 LB
------------------------------
Cas: 7440-66-6
RTECS #: ZG8600000
% Wt: 16-30
OSHA PEL: 10 MG/M3 (ZNO)
ACGIH TLV: 10 MG/M3 (ZNO)
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
SYMPS:METALLIC TASTE, DRY THROAT, COUGH,
-----------------------------
FATG. CHRONIC EXPOS TO ZINC METAL HAS NOT
-----------------------------
MATL IN SOLID FORMS IS NOT KNOWN TO BE
-----------------------------
LOCALIZED ARGYRIA (FROM SILVER), &/OR
-----------------------------
IN FINELY-DIVIDED FORM MAY PRDCE LOCALIZED
-----------------------------
THIS MATL IN FINELY-DIVIDED FROM MAY PRDCE
-----------------------------
CHRONIC INGEST MAY PRDCE DMG TO LIVER,
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: INHAL:ING 1:ACUTE EXPOS TO CADMIUM OXIDE FUME MAY PRDCE
PNEUM, TRACHEOBRONCH & PULM EDEMA. CHRONIC EXPOS TO CADMIUM (DUST/FUME)
MAY PRDCE GI SYMPS, ANEMIA, EOSINOPHILIA, RHINITIS, DISCOLORATION OF TEE TH,
MICROFRACTURES, KIDNEY DISEASE & CANCER. ING 2: ACUTE EXPOS MAY CAUSE
RESP TRACT IRRIT, FEVER, (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: CADMIUM:IARC MONOGRAPHS, SUPP, VOL 7, PG 139,
1987:GRP 2A. NTP 6TH ANNUAL RPT ON CARCINS, 1991:ANTIC TO BE (SUPP DATA)
Signs And Symptions Of Overexposure: HLTH HAZ:MUSCLE ACHE, CHILLS, COUGH, WEAK
& METALLIC TASTE. CHRONIC EXPOS MAY CAUSE DMG TO LIVER, KIDNEY, SPLEEN,
PANCREAS & BRAIN. ING 3:CHRONIC EXPOS MAY PRDCE ARGYRIA, PERM BLUE-GRAY
DISCOLORATION OF SKIN, EYES, MUC MEMBS & RESP TRACT. ING 4:ACUTE EXPOS
OF ZINC OXIDE FUME MAY CAUSE RESP TRACT IRRIT & "METAL
Medical Cond Aggravated By Exposure: PRE-EXISTING PULM DISEASES (E.G., BRONCH,
EMPHYSEMA) MAY BE AGGRAVATED BY INHAL EXPOS TO THIS MATL, PARTICULARLY AS
FUME. ADDNLY, EXPOS TO CADMIUM BY INHAL &/OR INGEST MAY AGGRAVATE PRE-
First Aid: INHAL:REMOVE SUBJECT FROM CONTAM AREA, ADMIN OXYGEN & SEEK MED
ATTN. KEEP SUBJECT WARM & AT REST. PERFORM ARTF RESP IF BRTHG HAS
STOPPED. SKIN:REMOVE CONTAM CLTHG. WASH AFFECTED AREA W/LG QTYS OF WATE R FOR
AT LST 5 MINS. SEEK MED ATTN IF NEC. EYES:FLUSH AFFECTED AREAS W/WATER FOR AT
LST 15 MINS. SEEK MED ASSISTANCE IF NEC. INGEST:IF SUBJECT IS CONSCIOUS,
INDUCE VOMIT. IF UNCON/CONVULSIVE,
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: CLEAN UP SPILLED MATERIAL SO AS TO MINIMIZE
DISPERSION OF DUST. WET SWEEPING OR VACUUMING USING HEPA FILTRATION ARE
RECOMMENDED METHODS. RQ:ING 1:1 LB. ING 2:5000 LBS. ING 3:1000 LBS. ING 4:
1000 LBS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS (FP N). RETURN TO MANUFACTURER FOR RECLAIM.
Handling And Storage Precautions: DO NOT STORE AT HIGHLY-ELEVATED TEMPS/IN
PROXIMITY TO INCOMPAT MATLS. DANGER. CONTAINS CADMIUM. CANCER HAZ. AVOID
CREATING DUST.
Other Precautions: CAN CAUSE LUNG & KIDNEY DISEASE. BRAZING ALLOYS MAY BE
USED W/SEPARATELY-APPLIED FLUX WHICH, WHEN HEATED, MAY EMIT IRRIT &/OR
TOX GASES & FUMES. CONSULT MSDS FOR SPECIFIC FLUX IN USE TO DETERM ITS
HAZ S & APPROP PROT MEASURES. FOR
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: USE DRY POWDER. DO NOT USE WATER.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: IN FINELY-DIVIDED FORM, THIS MATL MAY IGNITE
WHEN EXPOS TO FLAME/BY RXN W/INCOMPATL MATLS. FIRES/EXPLOS INVOLVING THIS
MATL MAY RELS POTNTLY TOXIC (SUPP DATA)
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF EXPOSURE LEVELS EXCEED OSHA PEL(S), WEAR NIOSH/ MSHA
APPROVED RESPIRATOR HAVING PROTECTION FACTOR APPROPRIATE TO AIRBORNE
CONCENTRATIONS OF CONTAMINANTS GENERATED.
Ventilation: USE MECH LOC EXHST VENT ADEQ TO MAINTAIN AIRBORNE CONCS OF ALL
COMPONENTS & THEIR DECOMP PRODS TO W/IN THEIR
Other Protective Equipment: WEAR APPROP PROT CLTHG TO PVNT SKIN INJURIES FROM
HAZS OF BRAZING &/OR FOR PRLNG/RPTD CONT W/FINELY-DIVIDED
Work Hygienic Practices: TO AVOID INGESTION OF MATERIAL, WASH HANDS & FACE
BEFORE EATING, DRINKING OR CONSUMPTION OF TOBACCO.
Supplemental Safety and Health: EXPLO HAZ:EMISSIONS OF METAL/METAL OXIDE FUMES
OF INGS. MATLS TO AVOID:PEROXIDES, PEROXYFORMIC ACID, CHLORINE &
FLUORINE, PERMONOSULFURIC ACID, CHLORATES, CRO3, MN & CA CHLORIDES, CS2,
HYDRAZINE MONON ITRATE, NITROBENZENE, FE(CO)5, SELENINYL BROMIDE. EXPLAN OF
CARCIN:CARCIN. HUMAN:LUNG, PROSTATE, RENAL SYSTEM EFTS.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
M.P/F.P Text: >1110F,>599
Spec Gravity: 8.79-9.53
Solubility in Water: INSOLUBLE
Appearance and Odor: LIGHT YELLOW METAL IN FORM OF WIRE, ROD, STRIP, PWDR/
PREFORMED SHAPES(ODORLESS
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: STRONG OXIDIZERS, SE, TE, MG, ACETYLENE, NH3, HNO3, AZIDES,
ETHANOL, ETHYLENE IMINE, CF3, INORG & ORGANIC (SUPP DATA)
Hazardous Decomposition Products: HEATING AT BRAZING TEMPERATURES MAY LIBERATE
OXIDES OF METALS IN INGREDIENTS SECTION, AS FUME.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: EASY-FLO 45
Cage: 6A753
Company Name: HANDY & HARMAN
Street: 1770 KINGS HIGHWAY
Zipcode: 06430-5317
Label Required IND: Y
Date Of Label Review: 11/24/1993
Status Code: C
Label Date: 11/24/1993
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: AVOID CREATING DUST. DO NOT STORE AT HIGHLY ELEVATED
TEMPS/IN PROXIMITY TO INCOMPATIBLE MATERIALS. ACUTE:INHALATION:MAY CAUSE
RESPIRATORY TRACT IRRITATION, METAL FUME FEVER, PNEUMONITIS & PULMONARY
ED EMA. SKIN:FINELY DIVIDED PARTICLES MAY PRODUCE LOCALIZED IRRITATION,
ARGYRIA, DISCOLORATION & DERMATITIS. EYE:MAY PRODUCE ARGYRIA, IRRITATION,
CONJUNCTIVITIS & ULCERATION OF CORNEA. INGEST:GASTRIC IRR ITATION,
VOMITING, ABDOMINAL PAIN, HEMORRHAGE, DIARRHEA. CHRONIC:CANCER
HAZARD.CONTAINS CADMIUM WHICH IS LISTED AS A HUMAN LUNG, PROSTATE & RENAL
SYSTEM CARCINOGEN (FP N). CAN CAUSE LUNG & KIDNEY DISE ASE. MAY DAMAGE
LIVER, SPLEEN, PANCREAS & BRAIN.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:XD 4229 AND ARALDITE 2002 COMPONENT A KIT
Kit Part:Y
CAGE:76323
POLYMERS
CAGE:99384
CAGE:76323
============= Composition/Information on Ingredients =============
Ingred Name:MODIFIED BISPHENOL-A EPOXY RESIN CONTAINING REACTIVE
DILUENT
Fraction by Wt: 100% %
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:> 5000 MG/KG ORAL LD50 (RATS)
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:STRONG IRRITANT TO SKIN IN UNCURED
STATE. STRONG EYE IRRITANT. NOT ACCUTELY HARMFUL BY INGESTION. NOT
EXPECTED TO BE AN INHALATION HAZARD.
Explanation of Carcinogenicity:PRODUCT CONTAINS NO INGREDIENTS
CURRENTLY CLASSIFIED AS CARCINOGENIC BY NTP, IARC OR OSHA.
Effects of Overexposure:EYE IRRITATION, SKIN IRRITATION
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN CONTACT: IMMEDIATELY REMOVE LIQUIDS BY WIPING WITH
DISPOSABLE TOWELS AND THEN CLEANSE THE SKIN WITH RESIN-REMOVING
CREAM, FOLLOWED BY WASHING WITH SOAPY WATER. DO NOT USE SOLVENTS.
EYE: IMMEDIATE LY FLUSH WITH WATER FOR 15 MINUTES. INHALATION:
REMOVE TO FRESH AIR. INGESTION: IMMEDIATELY RINSE MOUTH WITH WATER.
DRINK PLENTY OF WATER. SEEK MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>392F,>200C
Lower Limits:NONFLAMMABLE
Upper Limits:NONFLAMMABLE
Extinguishing Media:WATERSPRAY OR FOAM OR CARBON DIOXIDE OR DRY POWDER
OR VAPORISING LIQUID
Fire Fighting Procedures:DO NOT USE WATER JETS. IN A SERIOUS FIRE IT
MAY BE NECESSARY TO WEAR A COMPRESSED AIR BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:AVOID PRODUCTS OF COMBUSTION WHILE
PUTTING OUT THE FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP WITH ABSORBENT MATERIAL (SAND,
SAWDUST, COTTON WASTE, PAPER TOWELS, ETC). REMOVE THE CONTAMINATED
CLEANING MATERIAL TO A SAFE PLACE PENDING DISPOSAL. THE AFFECTED
AREA SHOULD BE WASHED WITH D ETERGENT SOLUTION, PREFERABLEY HOT.
RINSE W/WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS SECURELY CLOSED. STOW
THE CONTAINERS AWAY FROM FOOD, FOOD CONTAINERS AND CLOTHING.
Other Precautions:HANDLING TECHNIQUES MUST ENSURE THAT NO UNCURED EPOXY
MATERIAL COMES INTO CONTACT WITH EYES OR SKIN. CLEANLINESS AND
TIDINESS IN WORKING ARE OF THE UTMOST IMPORTANCE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER NORMAL CONDITIONS
Ventilation:THE WORK AREA MUST BE ADEQUATELY VENTILATED. VENTILATED
BENCH HOODS SHOULD BE PROVIDED FOR MIXING.
Other Protective Equipment:OVERALLS, HEAVYDUTY APRONS, EMERGENCY
EYEWASH/SHOWER
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
WHENEVER THE FULLY CURED OR HARDENED MATERIAL IS TO BE MACHINED, THE
EQUIPMENT SHOULD BE PROVIDED WITH AN EFFECTIVE LOCAL EXTRACTION
UST MASK PROTECTING THE NOSE AND MOUTH.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NOT GIVEN
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:NOT GIVEN
Spec Gravity:NOT GIVEN
Evaporation Rate & Reference:NEGLIGIBLE
Solubility in Water:INSOLUBLE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AMINE-BASED HARDENERS SUPPLIED WITH KIT UNTIL READY FOR USE
Stability Condition to Avoid:MOISTURE
Hazardous Decomposition Products:CARBON DIOXIDE AND CARBON MONOXIDE
UPON BURNING
Conditions to Avoid Polymerization:CONTACT WITH AMINE-BASED HARDENER
BEFORE READY FOR USE. WHEN BLENDED PRODUCT WILL HARDEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE LOCAL,
STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BOSTIK
Kit Part:Y
CAGE:KO195
CAGE:98502
CAGE:KO195
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENTS
Fraction by Wt: 45.0%
ACGIH TLV:100-400 PPM
Ingred Name:POLYESTER RESIN
Fraction by Wt: 19.1%
Ingred Name:ISOCYANATE PREPOLYMER (ALIPHATIC)
Fraction by Wt: 16.5%
Ingred Name:PIGMENTS
Fraction by Wt: 19.2%
Ingred Name:ADDITIVES
Fraction by Wt: 0.2%
===================== Hazards Identification =====================
Effects of Overexposure:INHALE-IRRITATE NOSE & THROAT. MAY CAUSE NAUSEA
OR VOMITING. MAY CAUSE EYE & SKIN IRRITATION.
======================= First Aid Measures =======================
First Aid:SKIN-WASH WITH SOAP & WATER. EYE-FLUSH WITH WATER; CONSULT
DOCTOR. INHALE-REMOVE TO FRESH AIR;CONSULT DOCTOR. INGESTION.
INDUCE VOMITING;CONSULT DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:23F, -5C TCC
Lower Limits:1.1
Extinguishing Media:C02 OR DRY CHEM FOR SMALL; ALCOHOL FOAM FOR LARGE
FIRES.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE.USE AIR SUPPLIED
R3SUCE EQUIPMENT.
Unusual Fire/Explosion Hazard:DO NOT APPLY TO HEATED SURFACES OR IN
AREAS WHERE ELECTRICAL SPARKS MAY BE PRESENT.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH SAWDUST OR OIL ABSORBING COMPOUND.
WASH AREA WITH DETERGENT AND WATER. USE ADEQUATE VENTILATION TO
CLEAR FUMES FROM AREA. AVOID SPARKS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE UNDER 100F. KEEP AWAY FROM HEAT.
SPARKS & OPEN FLAME. KEEP CONTAINERS CLOSED WHEN NOT IN USE.
Other Precautions:DO NOT STORE OR MIX WITH STRONG OXIDANTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AIR SUPPLIED RESPIRATOR OR SUITABLE CHEMICAL
CARTRIDGE.
Ventilation:TO MEET TLV
Other Protective Equipment:COVERALLS, APRON, NON-SPARKING SAFETY SHOES,
ETC.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:175-320F
Vapor Density:>AIR
Evaporation Rate & Reference:ETHER
Percent Volatiles by Volume:57.4
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS
Hazardous Decomposition Products:CO & COMBUSTION PRODUCTS OF VARIOUS
PIGMENTS
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE WITH CARE SANITARY LAND FILL
PREFERABLE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CHROMATE INDICATOR - GC CODE 140
Preparer's Name:WILLIAM DIGNIN
CAGE:56733
CAGE:56733
============= Composition/Information on Ingredients =============
Ingred Name:CHROMIC ACID, DIPOTASSIUM SALT; (POTASSIUM CHROMATE) (SARA
III)
CAS:7789-00-6
RTECS #:GB2940000
Fraction by Wt: 2-5%
OSHA PEL:C,0.1 MG/M3 CRO3
ACGIH TLV:0.5 MG CR/M3; 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN-MAY IRRITATE OR BURN SKIN.
EYE-WILL BURN OR SEVERELY IRRITATE EYES. INGESTION-MAY IRRITATE OR
BURN MOUTH, THROAT AND STOMACH. MAY CAUSE SERIOUS DAMAGE TO MOUTH,
THROAT AND STOMACH.
Explanation of Carcinogenicity:THIS PRODUCT CONTAINS A SUBSTANCE WHICH
IS ON THE CALIFORNIA PROPOSITION 65 LIST OF CHEMICALS KNOWN TO
CAUSE CANCER.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION-NOT APPLICABLE. SKIN-WASH WITH WATER. CONSULT A
PHYSICIAN. EYE-FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF WATER
CONTINUOUSLY FOR AT LEAST 15 MIN. CONSULT A PHYSICIAN IMMEDIATELY.
INGESTION-UNL ESS PATIENT IS UNCONSCIOUS, HAVING CONVULSIONS, OR
CANNOT SWALLOW, GIVE MILK OR WATER IMMEDIATELY. THEN CALL A
PHYSICIAN TO FIND OUT IF YOU SHOULD MAKE THE PATIENT VOMIT.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:NONE
Extinguishing Media:USE MEDIA APPROPRIATE FOR THE SURROUNDING FIRE.
Fire Fighting Procedures:NO SPECIAL FIRE FIGHTING INSTRUCTIONS.
Unusual Fire/Explosion Hazard:NO SPECIAL HAZARDS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE CLOTHING. CONTAIN WITH
ABSORBENT AND SHOVEL INTO PLASTIC BAGS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED & SEALED
WHEN NOT IN USE. STORE IN A COOL, DRY AREA. DO NOT ADD WATER OR ANY
OTHER MATERIAL TO CONTAINER.
Other Precautions:DISPOSE OF CONTAINER AFTER USE. DO NOT REUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NEEDED UNDER NORMAL CONDITIONS OF USE.
Ventilation:NORMAL ROOM VENTILATION.
Other Protective Equipment:PLASTIC OR RUBBER APRON.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. HAVE EYE WASH
AND SAFETY IN WORK AREA. REMOVE CONTAMINATED CLOTHING.
Supplemental Safety and Health
WASH CONTAMINATED CLOTHING BEFORE REUSE. IF LIQUID IS ABSORBED INTO
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:=100.C, 212.F
Spec Gravity:1 (H2O=1)
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:ODORLESS DARK ORANGE LIQUID.
Percent Volatiles by Volume:95
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN WASTE MANAGEMENT FACILITY OR IN
COMPLIANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS. IF SPILL IS
NOT CONTAMINATED YOU MAY BE ABLE TO DISPOSE OF MATERIAL WHERE
NORMALLY USED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HARD-TOP
CAGE:53798
CAGE:53798
============= Composition/Information on Ingredients =============
Ingred Name:ALIPHATIC PETROLEUM DISTILLATES
CAS:64742-88-7
Fraction by Wt: 50%
Other REC Limits:100 PPM
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL OR FATAL IF SWALLOWED.CONTAINS
PETROLEUM DISTILLATES.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:DIRECT CONTACT MAY RESULT IN
IRRITATION.SKIN:PROLONGED OR REPEATED CONTACT MAY RESULT IN
IRRITATION.INGEST:HARMFUL OR FATAL IF SWALLOWED.CONTAINS PETROLEUM
DISTILLATES.INHAL:PROLONGED OR REPEATED BREATHING OF VAPORS MAY
RESULT IN HEADACHE,NAUSEA OR DIZZINESS.
Medical Cond Aggravated by Exposure:N/K
======================= First Aid Measures =======================
First Aid:EYES:FLUSH EYES IMMEDIATELY W/ PLENTY OF COOL H*2O FOR AT
LEAST 15 MINUTES.IF IRRITATION PERSISTS,CONTACT PHYSICIAN.SKIN:WASH
PROMPTLY W/ PLENTY OF SOAP & WATER.IF IRRITATION PERSISTS,CONTACT
MD.INGES T:DO NOT INDUCE VOMITING.CONTAINS PETROLEUM
DISTILLATES.CONTACT MD OR POISON CONTROL CENTER IMMED.INHAL:REMOVE
TO FRESH AIR.IF DIFFICULTY IN BREATHING OR OTHER SYMPTOM
PERSISTS,CONTACT A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:105F,40.56C
Lower Limits:N/K
Upper Limits:N/K
Extinguishing Media:CARBON DIOXIDE,FOAM OR DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .WATER MAY BE INEFFECTIVE BECAUSE OF THE
SOLVENT NATURE OF THIS PRODUCT.
Unusual Fire/Explosion Hazard:BURNING OF THIS PRODUCT MAY RESULT IN THE
FORMATION OF CARBON MONOXIDE AND/OR CARBON DIOXIDE GASES.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF HEAT,SPARKS OR OPEN
FLAME.VENTILATE THE AREA.ABSORB WITH COMMERCIAL OIL ABSORBENT,SAND
OR VERMICULITE.FLUSH ANY RESIDUES WITH PLENTY OF WATER AND A GOOD
DETERGENT TO THE DRAIN.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:USE ONLY OUTDOORS OR WITH ADEQUATE
LOCAL MECHANICAL VENTILATION.COMBUSTIBLE.STORE IN A COOL,DRY PLACE
AWAY FROM HEAT,SPARKS AND OPEN FLAME.
Other Precautions:KEEP CONTAINER TIGHTLY CLOSED WHEN NOT IN USE.DO NOT
THIN THIS PRODUCT.DO NOT USE ON TENNIS COURTS.DO NOT APPLY BEFORE
OR DURING HEAVY RAIN.NEW BLACKTOP SHOULD BE WEATHERED 90 DAYS
BEFORE SEALING.AVOI D BREATHING VAPOR/SPRAY MIST. (SEE SUPP)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Other Protective Equipment:A SOURCE OF COOL,CLEAN WATER NEARBY IN CASE
OF ACCIDENTAL EYE OR SKIN CONTACT.
Work Hygienic Practices:N/K
Supplemental Safety and Health
% VOLAT BY WT:50%.OTHER PREC:FOR INDUSTRIAL USE ONLY.KEEP OUT OF THE
REACH OF CHILDREN.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:310F,154.4C
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/K
Vapor Density:N/K
Spec Gravity:0.907 (WATER=1)
Evaporation Rate & Reference:N/K
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK,OPAQUE LIQUID WITH A SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:EXPOSURE TO HEAT,SPARKS OR OPEN FLAMES.
Hazardous Decomposition Products:BURNING OF THIS PRODUCT MAY RESULT IN
THE FORMATION OF CARBON MONOXIDE AND/OR CARBON DIOXIDE GASES.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .DO NOT REUSE EMPTY CONTAINERS
FOR ANY PURPOSE.FLUSH THOROUGHLY WITH WATER,CRUSH OR PERFORATE AND
DISCARD,OR GIVE RINSED D RUMS TO A DRUM RECONDITIONER FOR
RECYCLING.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:40-6162 METADI I
Preparer's Name:T. DERAM
CAGE:09410
CAGE:09410
============= Composition/Information on Ingredients =============
Ingred Name:POLYPROPYLENE GLYCOL; (POLYALKYLENE GLYCOL)
CAS:25322-69-4
RTECS #:TR5250000
Fraction by Wt: 40-60%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DIAMOND; (DIAMOND POWDER (VARIABLE ACCORDING TO GRADE))
CAS:7782-40-3
Fraction by Wt: 1-30%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:STEARIC ACID; (FATTY ACID)
CAS:57-11-4
RTECS #:WI2800000
Fraction by Wt: 1-30%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:OLEIC ACID, POTASSIUM SALT; (POTASSIUM SOAP)
CAS:143-18-0
RTECS #:RK1150000
Fraction by Wt: <10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLYETHYLENE GLYCOL
CAS:25322-68-3
RTECS #:TQ3500000
Fraction by Wt: <10%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: ABRASIVE PARTICLES MAY IRRITATE
IF RUBBED IN EYES. SKIN: MILD DEFATTING. INGESTION: MILD
IRRITATION, NAUSEA.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:SKIN: WASH THOROUGHLY WITH SOAP AND WATER. EYES: FLUSH
THOROUGHLY WITH WATER FOR AT LEAST 15 MINUTES, LIFTING EYE LIDS
OCCASIONALLY. INGESTION: GIVE 2 GLASSES OF WATER, INDUCE VOMITING.
NO HARMFUL EFF ECT EXPECTED. INHALATION: REMOVE FROM EXPOSURE.
SUPPORT BREATHING (GIVE ARTIFICIAL RESPIRATION/OXYGEN) .
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:260F,127C
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP RESIDUE WITH SOAP AND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. WEAR NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:GENERAL VENTILATION SUFFICIENT TO KEEP AIRBORNE
CONCENTRATION BELOW CURRENT EXPOSURE LIMITS .
Other Protective Equipment:NONE.
Work Hygienic Practices:GOOD PERSONAL HYGIENE TO BE FOLLOWED AT ALL
TIMES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>390F,>199C
Vapor Pres:<0.01
Spec Gravity:>1 (H*2O=1)
Solubility in Water:DISPERSIBLE
Appearance and Odor:THICK PASTE-ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:00747 HI-TECH SAFETY SOL & DEQ, 00747H
CAGE:DO642
CAGE:DO642
CAGE:09800
============= Composition/Information on Ingredients =============
Ingred Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: 3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM/30000STEL;94
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 97%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:350 PPM
ACGIH TLV:350 PPM/450STEL;9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CHRONIC:REPORTS HAVE ASSOCIATED
REPEATED & PROLONGED OVEREXPOSURE TO SOLVENTS W/PERMANENT BRAIN &
NERVOUS SYSTEM DAMAGE, ALSO KIDNEY & LIVER DAMAGE. ACUTE:IN A
CONFINED AREA VAPORS IN HIGH CONCENTRATI ON ARE ANESTHETIC.
IRRITANT TO SKIN & UPPER RESPIRATORY SYSTEM. HARMFUL OR FATAL IF
SWALLOWED. (SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:OVEREXPOS MAY RSLT IN
LIGHT-HEADEDNESS, STAG GAIT, GIDD & POSS NAUS.
CHLOROCARBON/CHLOROFLUOROCARBON (CFC) MATLS HAVE PRDCED SENSIT OF
THE MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS & COULD HAV E A
SIMILAR EFT IN HUMANS. ADRENOMIMETICS (E.G., EPINEPHRINE) MAY BE
CONTRAINDICATED EXCEPT FOR LIFE- (SEE SUPP DATA)
Medical Cond Aggravated by Exposure:NONE ESTABLISHED.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE PATIENT TO FRESH AIR. EYE:FLUSH W/WATER FOR AT
LEAST 15 MINUTES. SKIN:WASH W/SOAP & WATER. INGEST:CALL MD
IMMEDIATELY. DO NOT INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NONE
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE-WATER MAY BE USED TO
KEEP FIRE EXPOSED CONTAINERS COOL. WEAR NIOSH/MSHA APPRVD PRESS
DEMAND SCBA & FULL PROT EQUIP .
Unusual Fire/Explosion Hazard:KEEP AT ROOM TEMPERATURE AS EXPOSURE TO
DIRECT SUNLIGHT OR OTHER HEAT MAY CAUSE BURSTING. THERMAL DECOMP
PROD MAY INCL HCL & PHOSGENE .
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA - ESPECIALLY LOW PLACES WHERE
VAPORS WILL COLLECT. AVOID BREATHING OF VAPORS AND REMOVE W/INERT
ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120 F. KEEP AT ROOM
TEMP AS EXPOS TO DIRECT SUNLT/HEAT MAY CAUSE BURSTING. DO NOT
PUNCTURE/INCIN. AVOID BRTHG OF VAP/SPRAY MIST.
Other Precautions:KEEP AWAY FROM CHILDREN. DO NOT SPRAY NEAR FIRE OR
OPEN FLAME. NO SMOKING IN AREA OF USE. DO NOT USE IN GEN VICINITY
OF ARC WELDING/OPEN FLAMES/HOT SURF. HEAT/UV RADIA MAY CAUSE THE
FORMATION OF CHLOR IDES, FLUORIDES & PHOSGENE .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID BREATHING OF VAPOR OR SPRAY MIST.
NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN
.
Ventilation:PROVIDE LOC EXHAUST VENT IN VOL & PATTERN TO KEEP TLV OF
ALL HAZ INGRED BELOW ACCEPTABLE LIMIT.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:SUSTAINING USED IN HUMANS ACUTELY OR CHRONICALLY
EXPOSED TO CHLOROCARBONS OR CFC'S.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:<0F,<-18C
Vapor Density:HVR/AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:CLEANERS
Percent Volatiles by Volume:100 WT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:DO NOT STORE ABOVE 120 F.
Hazardous Decomposition Products:IF SPRAYED INTO OPEN FLAME. FUMES MAY
CONTAIN TOX FUMES OF CHLORIDES. HCL & PHOSGENE .
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE - DISPOSE IN ACCORDANCE
W/FEDERAL, STATE AND LOCAL REGULATIONS REGARDING POLLUTION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NDC 300-3629-01 LEUPROLIDE ACETATE INJECTION KIT
CAGE:60060
CAGE:60060
============= Composition/Information on Ingredients =============
Ingred Name:LEUPROLIDE ACETATE
CAS:74381-53-6
RTECS #:OH6390000
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INJECTION: INCREASE IN LH, FSH, &
MALE/FEMALE SEX HORMONES, REDUCTIONS IN HORMONES TO CASTRATE OR
MENOPAUSAL LEVEL, HOT FLASHES, SWEATS, IMPOTENCE, DECREASED
LIBIDO/TESTICULAR SIZE, HEADACHE, MOOD CHA NGES, AMENORRHEA,
VAGINAL DRYNESS, FERTILITY SUPPRESSION, DECREASED BONE DENSITY.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INJECTION: INCREASE IN LH, FSH, & MALE/FEMALE
SEX HORMONES, REDUCTIONS IN HORMONES TO CASTRATE OR MENOPAUSAL
LEVEL, HOT FLASHES, SWEATS, IMPOTENCE, DECREASED LIBIDO/TESTICULAR
SIZE, HEADACHE, MOOD CHA NGES, AMENORRHEA, VAGINAL DRYNESS,
FERTILITY SUPPRESSION, DECREASED BONE DENSITY.
Medical Cond Aggravated by Exposure:DUE TO TEMPORARY INCREASE OF SEX
HORMONE LEVELS DURING FIRST FEW WEEKS OF TREATMENT, ISOLATED CASES
OF WORSENING IN SIGNS/SYMPTOMS OF HORMONALLY-DEPENDENT CONDITIONS
HAVE BEEN REPORTED.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/COPIOUS AMOUNTS OF WATER.
INHALATION/INGESTION: REMOVE TO FRESH AIR. THERE IS NO KNOWN
ANTIDOTE. PROVIDE SYMPTOMATIC OR SUPPORTIVE CARE, MONITORING
HORMONE/SEXUAL FUNCTION AS NECESS ARY. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE APPROPRIATE MEDIA FOR UNDERLYING CAUSE OF FIRE.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING & SELF-CONTAINED
BREATHING APPARATUS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. SWEEP UP SPILLAGE.
AVOID DUST. PLACE IN APPROPRIATE CONTAINER FOR DISPOSAL. VENTILATE
& WASH SPILL AREA.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE ONLY IN CONTAINERS APPROVED FOR
STORAGE OF THIS MATERIAL. AVOID DUST.
Other Precautions:AVOID CONTACT W/SOLID OR ITS SOLUTIONS. WOMEN OF
CHILD BEARING POTENTIAL MUST BE EXCLUDED FROM WORKING DIRECTLY
W/PRODUCT WHICH IS NOT PACKAGED IN CLOSED CONTAINER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROVED RESPIRATOR W/HIGH EFFICIENCY
PARTICULATE FILTER OR SUPPLIED-AIR (IF HANDLING POWDER).
Ventilation:LOCAL VENTILATION TO CONTROL DUST AT ITS SOURCE
Supplemental Safety and Health
LH: LUTEINIZING HARMONE; FSH: FOLLICLE-STIMULATING HARMONE. CONTINUOUS
ADMINISTRATION OF THERAPEUTIC DOSES ACTS AS POTENT, BUT REVERSIBLE
INHIBITOR OF GONADOTROPIN SECRETION BY THE PITUITARY, RESULTIN G IN
INHIBITION OF OVARIAN & TESTICULARSTEROID PRODUCTION.
================== Physical/Chemical Properties ==================
Solubility in Water:COMPLETE
Appearance and Odor:WHITE, FLOCCULENT POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HYPOCHLORITE SOLUTIONS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF MATERIAL IN ACCORDANCE W/APPLICABLE
FEDERAL, STATE, & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PREMIUM GEAR OIL (MP) 80W-90
CAGE:7X110
CAGE:7X110
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, SOLVENT-DEWAXED HEAVY
PARAFFINIC. PERCENTAGE IS FOR MIXTURE CONTAINING INGR. #1-7.
CAS:64742-65-0
RTECS #:PY8038500
Fraction by Wt: 90-97%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:SOLVENT,DEWAXED RESIDUAL OIL (PETROLEUM)
CAS:64742-62-7
Fraction by Wt: <90-97%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:REFINED HEAVY PARAFFINIC DISTILLATES
CAS:64741-88-4
Fraction by Wt: <90-97%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:MINERAL OIL
CAS:72623-83-7
Fraction by Wt: <90-97%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:RESIDUAL OILS, SOLVENT REFINED
CAS:64742-01-4
Fraction by Wt: <90-97%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:DISTILLATES, HYDROTREATED HEAVY PARAFFINIC
CAS:64742-54-7
RTECS #:PY8035500
Fraction by Wt: <90-97%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:RESIDUAL OILS, HYDROTREATED
CAS:64742-57-0
Fraction by Wt: <90-97%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:EXTREME PRESSURE, OXIDATION AND RUST INHIBITOR
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
Ingred Name:POUR DEPRESSENT
Fraction by Wt: <2%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MILD EYE IRRITANT.
TRANSIENT/SLIGHT SKIN IRRITATION. LOW INHALATION HAZARD. MISTS
ABOVE TLV MAY CAUSE CHEMICAL PNEUMONITIS. LOW HAZARD BY INGESTION.
VERY LARGE AMOUNTS MAY CAUSE CENTRAL NERVOUS SYSTEM EFFECTS.
CHRONIC: PROLONGED/REPEATED CONTACT MAY CAUSE DERMATITIS OR
FOLLICULITIS.
Explanation of Carcinogenicity:NONE OF THE CHEMICALS IN THIS PRODUCT IS
LISTED BY IARC, NTP OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYE: MILD IRRITATION. SKIN: SLIGHT TRANSIENT
IRRITATION. INHALATION: DROWSINESS, DIZZINESS, HEADACHE, NAUSEA,
LUNG IRRITATION. INGESTION: HEADACHE, DROWSINESS, NAUSEA, VOMITING,
DIARRHEA. INJECTION: E RYTHEMA, EDEMA, IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH WITH LARGE QUANTITIES OF WATER FOR AT LEAST 15
MINUTES AND CALL A PHYSICIAN IF ANY COMPLICATION ARISE. SKIN:
REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER. INHALATION:
REMOVE TO FR ESH AIR. GIVE OXYGEN/CPR IF NEEDED. SEEK MEDICAL AID.
INGESTION: DO NOT INDUCE VOMITING. SEEK MEDICAL AID. INJECTION:
SUBCUTANEOUS INJECTION IS A MEDICAL EMERGENCY. SEEK MEDICAL AID
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:428F,220C
Extinguishing Media:USE CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:WATER MAY CAUSE FROTHING. COMBUSTION OR
HEAT OF FIRE MAY PRODUCE HAZARDOUS DECOMPOSITION PRODUCTS AND
VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.
REMOVE IGNITION SOURDES, PROVIDE ADEQUATE VENTILATION, CONTAIN
LEAK. ABSORB WITH SUITABLE MATERIAL SUCH AS VERMICULITE OR SAND.
PLACE IN APPROPRIATE CONTAINER AND COVER. WASH AREA WITH SOAP AND
WATER.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 150F, DO NOT APPLY HIGH
HEAT OR FLAME TO CONTAINER. KEEP SEPARATE FROM STRONG OXIDIZING
AGENTS.
Other Precautions:EMPTY CONTAINERS MAY CONTAIN PRODUCT RESIDUE WHICH
COULD INCLUDE FLAMMABLE OR EXPLOSIVE VAPORS. CONSULT APPROPIATE
AUTHORITIES BEFORE REUSING, RECONDITIONING, RECLAIMING, RECYCLING,
OR DISPOSING OF EM PTY CONTAINERS AND/OR WASTE RESIDUE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMALLY NONE REQUIRED. IF HIGH VAPOR OR MIST
CONCENTRATIONS EXPECTED, USE RESPIRATOR APPROVED FOR ORGANIC VAPOR
OR MISTS.
Ventilation:USE IN WELL VENTILATED AREA. IN CONFINED SPACES, MECHANICAL
VENTILATION MAY BE REQUIRED TO KEEP BELOW PEL/TLV.
Other Protective Equipment:WEAR BODY-COVERING WORK CLOTHES TO AVOID
PROLONGED OR REPEATED EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NOTE TO PHYSICIAN: ON INGESTION, AN OIL VISCOSITY OF APPROXIMATELY 800
SUS AT 100F, PRESENTS NO ASPIRATION HAZARD. HOWEVER, FOR LARGE
QUANTITIES, LAVAGE MAY STILL BE ADVISED.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:700F,371C
Vapor Pres:0.0003,25C
Vapor Density:>1
Spec Gravity:0.89 (60F)
Viscosity:13.5-<24 CST
Evaporation Rate & Reference:<1 (BUTYL ACETATE = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER LIQUID, SULFURIZED ODOR.
Percent Volatiles by Volume:NEGL.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE
FROM BURNING.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL,
STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:40003 LPS HEAVY DUTY SILICONE LUBRICANT
Preparer's Name:JOE TAYELEY
CAGE:GO159
CAGE:GO159
CAGE:66724
============= Composition/Information on Ingredients =============
Ingred Name:L.P.G. (LIQUID PETROLEUM GAS) PROPELLANT(FLAMMABLE)
(PROPANE/ISOBUTANE 85/15)
CAS:68476-85-7
RTECS #:SE7545000
Fraction by Wt: 10-20%
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:1800 MG/CUM
Ingred Name:BENZIN, NAPHTHA, MINERAL SPIRITS, PETROLEUM NAPHTHA
CAS:8030-30-6
RTECS #:DE3030000
Fraction by Wt: 15-20%
Other REC Limits:STEL 400 PPM
OSHA PEL:500 PPM
ACGIH TLV:300 PPM
Ingred Name:SORBITAN MONOOLEATE
CAS:1338-43-8
RTECS #:WG2932400
Fraction by Wt: 0.25-1%
Ingred Name:DIMETHYL POLYSILOXANE (MONOMER: DIMETHYL SILOXANE),
SILICONE FLUID, DOW CORNING 200, POLYMETHYLSILOXANE
CAS:63148-62-9
RTECS #:JT6484500
Fraction by Wt: 5%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 65-80%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: DRYING.
INHALATION: HEADACHE, DIZZINESS, & NAUSEA.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION. SKIN: DRYING. INHALATION:
HEADACHE, DIZZINESS, & NAUSEA.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/COPIOUS AMOUNTS OF COLD WATER. SKIN: WASH
W/SOAP & WATER & THEN APPLY MEDICATED CREAM. INHALATION: REMOVE TO
FRESH AIR. INGESTION: AVOID ASPIRATION INTO LUNGS, WHICH MAY CAUSE
CHEMICAL P NEUMONIA. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, CO2, OR DRY CHEMICAL
Unusual Fire/Explosion Hazard:EXCESSIVE HEAT CREATED BY FIRE WILL CAUSE
AEROSOLS TO BURST.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE IGNITION SOURCES.
REMOVE LEAKING CONTAINER, MOP UP OR SOAK UP W/ABSORBENT MATERIAL &
DISCARD. DON'T FLUSH TO SEWER. FLOORS SHOULD BE THOROUGHLY CLEANED
AFTERWARDS W/SOAP & WATER BECAUSE THEY MAY BE SLIPPERY.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AEROSOLS BETWEEN 32-120F & BULK
BETWEEN 32-150F. STORE AWAY FROM IGNITION SOURCES.
Other Precautions:AVOID CONTACT W/SKIN. REMOVE OVERSPRAY FROM FLOORS TO
PREVENT FROM BECOMING SLIPPERY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED IF GOOD VENTILATION IS MAINTAINED.
FOR ENCLOSED AREAS, USE NIOSH APPROVED ORGANIC VAPOR CARTRIDGE
RESPIRATOR OR SELF-CONTAINED BREATHING APPARATUS.
Ventilation:LOCAL EXHAUST: USUALLY ADEQUATE. MECHANICAL: WHEN SPRAYING
IN ENCLOSED AREAS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text: 210F
Vapor Density:1
Spec Gravity:1
Evaporation Rate & Reference:(ETHYL ETHER = 1): 10
Solubility in Water:COMPLETE
Appearance and Odor:WHITE MILKY LIQUID W/SWEET ODOR.
Percent Volatiles by Volume:95%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS LIQUID CHLORINE OR SODIUM HYPOCHLORITE
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS, OPEN FLAMES, OR
IGNITION SOURCES
Hazardous Decomposition Products:CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. (D001).
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:14430-10 TO 14434-10 SHINE UP-ORIGINAL AEROSOL
Preparer's Name:TERRY A MEYERS
CAGE:0U826
CAGE:0U826
CAGE:32204
============= Composition/Information on Ingredients =============
Ingred Name:ISOPARAFFINIC HYDROCARBONS (NAPHTHA PETROLEUM),
HYDROTREATED HEAVY, NON AROMATIC HEAVY NAPHTHA) ISOPAR G
CAS:64742-48-9
Fraction by Wt: 10-20%
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 3-5%
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:DIMETHYL POLYSILOXANE (MONOMER: DIMETHYL SILOXANE),
SILICONE FLUID, DOW CORNING 200, POLYMETHYLSILOXANE
CAS:63148-62-9
RTECS #:JT6484500
Fraction by Wt: 1-5%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 70-80%
Ingred Name:BUTANE, N-BUTANE
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: 3-5%
Other REC Limits:800 PPM
OSHA PEL:800 PPM
ACGIH TLV:1900 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NO EFFECTS EXCEPT UNDER EXTREME
EXPOSURE CONDITIONS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NO EFFECTS EXCEPT UNDER EXTREME EXPOSURE
CONDITIONS.
Medical Cond Aggravated by Exposure:INDIVIDUALS W/CHRONIC RESPIRATORY
DISORDERS; ASTHMA, CHRONIC BRONCHITIS, EMPHYSEMA
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15-20 MINS. OBTAIN MEDICAL ATTENTION
IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:<20F PROPELLANT
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:NORMAL FIRE FIGHTING PROCEDURES MAY BE USED.
FIGHT FIRE FROM MAXIMUM DISTANCE/PROTECTED AREA. COOL/USE CAUTION
WHEN APPROACHING/HANDLING FIRE EXPOSED CONTAINERS
Unusual Fire/Explosion Hazard:CONTAINER MAY BURST IN HEAT OF FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. ABSORB
W/OIL-DRI/SIMILAR INERT MATERIAL. SWEEP/SCRAPE UP & CONTAINERIZE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE W/ADEQUATE
VENTILATION. KEEP FROM FREEZING. DON'T USE NEAR FIRE, FLAME/OTHER
IGNITION SOURCES. KEEP FROM TEMPS >120F.
Other Precautions:DON'T PUNCTURE/THROW IN FIRE. KEEP OUT OF REACH OF
CHILDREN. NEVER USE ON FLOORS/SURFACES THAT ARE WALKED ON, MAY BE
SLIPPERY. AVOID OVERSPRAY. DON'T PRESSURIZE/CUT/HEAT/WELD/EXPOSE
CONTAINER TO FLAME ; EXPLOSION COULD OCCUR.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL USE CONDITIONS.
Ventilation:GENERAL ROOM: ADEQUATE
Work Hygienic Practices:USE GOOD PERSONAL HYGIENE PRACTICES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:0.9
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DISPENSED AS CREAMY SPRAY W/MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:FIRE, FLAME/PILOT LIGHT, TEMPS >120F,
OTHER IGNITION SOURCES & FREEZING
Hazardous Decomposition Products:NORMAL PRODUCTS OF COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:RECYCLE EMPTY AEROSOL CAN TO NEAREST STEEL
RECYCLING CENTER. USE UP PACKAGE/GIVE TO SOMEONE WHO CAN. DISPOSE
OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:FBX DUCT INSULATION
CAGE:7X148
CAGE:7X148
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL FIBER (VITREOUS)
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:RESIN (CURED)
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: FIBERS AND DUST FROM HANDLING
PROUCT MAY CAUSE TRANSITORY IRRITATION OR RASH TO SKIN, EYES OR
RESPIRATORY TRACT. CHRONIC: NO CHRONIC EFFECTS ARE KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. DO NOT RUB.
IF IRRITATION CONTINUES, CONSULT MD. SKIN: WASH PARTICLES FROM SKIN
WITH SOAP AND WATER. DO NOT RUB. IF IRRITATION PERSISTS, CONSULT
MD. INH AL: REMOVE TO FRESH AIR. INGEST: CONSULT MD.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:IF FIBERS OR PARTICLES ARE RELEASED, USE
VACUUM OR WET CLEAN-UP PROCEDURES TO MINIMIZE AIRBORNE DUST.
DISPOSE TO SOLID WASTE LANDFILL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:MINIMIZE BLOWING DUST.
Other Precautions:DO NOT BREATHE DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED DUST RESPIRATOR IF TLV
IS EXCEEDED.
Ventilation:WORK AREAS SHOULD BE WELL VENTILATED TO MINIMIZE THE
POSSIBILITY OF EXCEEDING TLV LEVELS.
Other Protective Equipment:WEAR LOOSE FITTING CLOTHING.
Work Hygienic Practices:WASH AFTER HANDLING. LAUNDER WORK CLOTHES
SEPARATELY AND CLEAN WASHER AFTER USE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:YELLOW TO TAN; NEGLIGIBLE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, STRONG ALKALIS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:EMITS NORMAL COMBUSTION PRODUCTS (EG,
CO & CO2) IF EXPOSED TO FIRE OR HIGH TEMPERATURE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE AND LOCAL
REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PRISMA-FIL
CAGE:11107
CAGE:11107
============= Composition/Information on Ingredients =============
Ingred Name:PER MSDS
RTECS #:9999999ZZ
Fraction by Wt: NONE
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PERSONS SUSCEPTIBLE TO METHACRYLATES,
ACRYLATES & URETHANES MAY DEVELOP ALLERGIC RESPONSE. DERMAL;
REDNESS OR IRRITATION, SEVERE ALLERGIC RESPONSE MAY RESULT IN
BREATHNG DIFFICULTIES.
Explanation of Carcinogenicity:PER
MSDS:CARCINOGENICITY:NTP/IARC/OSHA:NO.
Effects of Overexposure:ALLERGIC RESPONSES. REDNESS, IRRIT, BREATHING
DIFFICULTIES.
Medical Cond Aggravated by Exposure:ALLERGIES TO METHACRYLATES,
ACRYLATES AND URETHANES.
======================= First Aid Measures =======================
First Aid:INGEST:CONSULT PHYSICIAN. SKIN:WASH WITH SOAP & WATER.
EYES:FLUSH WITH WATER FOR 15MINS AND CONSULT PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NOT ESTIMATED
Extinguishing Media:SAND, FOAM, CARBON DIXOIDE, DRY CHEMICALS.
Fire Fighting Procedures:FREMEN SHOULD WEAR PROTECTIVE CLOTHING AND
SELF-CONTAINED RESPIRATORS.
Unusual Fire/Explosion Hazard:DURING FIRE IRRITATIANG GASES MAY BE
PRESENT.
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP UP BULK MATERIAL AND PLACE IN LABELED
PLASTIC OR METAL CONTTAINER. AVOID GROSS SKIN CONTACT TO MINIMIZE
POSSIBILITY OF CONTACT DERMATITIS TO SENSITIVE INDIVIDUALS.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID STORAGE CONDITIONS ABOVE 50C.
Other Precautions:MATERIAL SENSITIVE TO VISIBLE LIGHT. STORE AWAY FROM
FOOD AND BEVERAGES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED DURING NORMAL USE OF THIS PRODUCT.
Ventilation:NONE REQUIRED DURING NORMAL INTENDED USE FO THE PRODUCT.
Other Protective Equipment:NOT REQUIRED FOR GENERAL HANDLING.
Work Hygienic Practices:OBSERVE NORMAL CARE FOR WORKING WITH CHEMICALS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:2.2G/CC
Solubility in Water:INSOLUBLE
Appearance and Odor:CREAMY PASTE,SHADES ARE OFF-WHITE TO YELLOW GREAY
WITH ACRYLATE ESTER ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDING AGENTS.
Stability Condition to Avoid:VISIBLE LIGHT ON PASTE. PROLONGED HEAT
AVOD 50C.
Hazardous Decomposition Products:POSSIBLE METHACRYLATES.
Conditions to Avoid Polymerization:SENSITIVE TO VISIBLE LIGHT, WILL
HARDEN DURING EXPOSURE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:40571 PRESERVATONE
CAGE:EO768
CAGE:32882
CAGE:EO768
============= Composition/Information on Ingredients =============
Ingred Name:DIBUTYL PHTHALATE (SARA III)
CAS:84-74-2
RTECS #:TI0875000
Fraction by Wt: 2.5-3.0%
Other REC Limits:5 MG/CUM
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3; 9192
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: HARMFUL/FATAL. EYES/SKIN:
IRRITANT
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INGESTION: HARMFUL/FATAL. EYES: IRRITANT.
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & EXCESS WATER. EYES: FLUSH PROMPTLY
W/EXCESS WATER FOR 15 MINS. INGESTION: DON'T INDUCE VOMITING. IF
CONSCIOUS, GIVE A GLASS OF WATER TO PERSON. INHALATION: REMOVE FROM
CONAMINATED AREA. GIVE CPR IF REQUIRED. OBTAIN MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:190F
Extinguishing Media:CO2, DRY CHEMICALS, FOAM
Fire Fighting Procedures:FIREFIGHTERS WEAR SELF-CONTAINED BREATHING
APPARATUS. FIGHT LIKE A FUEL OIL FIRE.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS EXPOSED TO HIGH
TEMPERATURES SUCH AS FIRE CONDITIONS MAY RUPTURE.
================== Accidental Release Measures ==================
Spill Release Procedures:WASH & CLEAN UP SMALL SPILLS W/WATER &
DETERGENT. PICK UP LARGE SPILLS W/INERT ABSORBENT & PLACE IN A
CONTAINER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:USE W/ADEQUATE VENTILATION. AVOID
CONTACT W/EYES, SKIN & BREATHING OF VAPORS. DON'T FLAME CUT, WELD,
OR MELT EMPTY CONTAINERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:VENTILATE W/AIR FLOW. USE IN WELL-VENTILATED
AREA.
Ventilation:LOCAL EXHAUST/MECHANICAL: ACCEPTABLE
Other Protective Equipment:SAFETY SHOWERS & EYE WASH FOUNTAIN
Supplemental Safety and Health
TRACE AMTS OF STRYENE, FORMALDEHYDE, & ETHYLENE GLYCOL, WHICH MAY BE
CANCER HAZARDS &/OR REPRODUCTIVE TOXICANTS, MAY BE CONTAINED IN
THIS PRODUCT. THE LEVELS IN THIS PRODUCT DON'T CONSTITUTE A SIGNIFI
CANT RISK.
================== Physical/Chemical Properties ==================
Vapor Density:>AIR
Spec Gravity:1.03
Evaporation Rate & Reference:SLOWER THAN ETHYL ETHER
Solubility in Water:DISPERSIBLE
Appearance and Odor:OPAQUE (MILKY) LIQUID W/CHARACTERISTIC ODOR.
Percent Volatiles by Volume:80%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, OXIDIZING AGENTS AS PEROXIDES
Hazardous Decomposition Products:CO, CO2 & ACRID FUMES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:02109 URSA SUPER PLUS SAE 15W-40
Preparer's Name:MANAGER, PRODUCT SAFETY
CAGE:2R503
CAGE:2R503
============= Composition/Information on Ingredients =============
Ingred Name:SEVERELY SOLVENT REFINED, SOLVENT DEWAXED HEAVY PARAFFINIC
PETROLEUM DISTILLATES
CAS:64742-65-0
RTECS #:PY8038500
Fraction by Wt: 80-95%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:ALKENYLSUCCINIMIDE DISPERSANT
Fraction by Wt: 3-10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIALKYLDITHIOPHOSPHORIC ACID, ZINC SALT
CAS:84605-29-8
Fraction by Wt: 0.1-0.9%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ZINC DITHIOPHOSPHATE (ZINC 0,0-BISISODECYL DITHIOPHOSPHATE)
CAS:25103-54-2
Fraction by Wt: 0.1-0.9%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS >5000 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION OF HIGH
CONCENTRATIONS MAY CAUSE RESPIRATORY IRRITATION, HEADACHE & NAUSEA.
CONTACT WITH SKIN & EYES MAY CAUSE IRRITATION. INGESTION MAY CAUSE
GI TRACT IRRITATION. CHRONIC: NO ADVERS E EFFECTS HAVE BEEN
DOCUMENTED IN HUMANS AS A RESULT OF CHRONIC EXPOSURE.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:INHALED-HEADACHE, NAUSEA, IRRITATION OF NOSE &
THROAT, DROWSINESS. INGESTED-ABDOMINAL DISCOMFORT, NAUSEA,
DIARRHEA. EYES-TEMPORARY DISCOMFORT. SKIN-LOCAL REDNESS, SWELLING.
Medical Cond Aggravated by Exposure:REPEATED SKIN CONTACT MAY AGGRAVATE
AN EXISTING DERMATITIS.
======================= First Aid Measures =======================
First Aid:EYES-FLUSH WITH LOTS OF WATER FOR SEVERAL MINUTES. GET
MEDICAL ATTENTION IF IRRITATION PERSISTS. SKIN-WASH SKIN WITH
PLENTY OF SOAP & WATER. GET MEDICAL ATTENTION IF IRRITATION
PERSISTS. INGESTED-IF C ONSCIOUS, GIVE 2 GLASSES OF WATER. GET
MEDICAL ATTENTION. INHALED-IF SYMPTOMS OCCUR, REMOVE TO FRESH AIR.
GET MEDICAL ATTENTION IF BREATHING BECOMES DIFFICULT OR
RESPIRAATORY IRRITATION PERSISTS.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>435F,>224C
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
WATER OR FOAM MAY CAUSE FROTHING.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE GEAR. COOL FIRE EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:HYDROGEN SULFIDE MAY BE RELEASED WHEN
OVERHEATED.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. AVOID BREATHING VAPOR. WEAR
APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT, INCLUDING RESPIRATORY.
CONTAIN SPILL IF POSSIBLE. WIPE UP OR ABSORB ON SUITABLE MATERIAL &
SHOVEL UP. PREVENT ENT RY INTO SEWERS & WATERWAYS. AVOID CONTACT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PERIODS OF EXPOSURE TO HIGH
TEMPERATURES SHOULD BE MINIMIZEDWATER CONTAMINATION SHOULD BE
AVOIDED.MINIMUM FEASIBLE HANDLING TEMPS SHOULD BE MAINTAINED
Other Precautions:WHEN OVERHEATED, PRODUCT MAY RELEASE HYDROGEN SULFIDE
GAS. HYDROGEN SULFIDE CONCENTRATIONS ABOVE PERMISSABLE
CONCENTRATIONS CAN CAUSE IRRITATION OF EYES & RESPIRATORY TRACT,
HEADACHE, DIZZINESS, NAUSE A, VOMITING, DIARRHEA, PULMONARY EDEMA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE
OR AN EMERGENCY OCCURS; WEAR AN MSHA/NIOSH APPROVED RESPIRATOR OR
AN AIR-SUPPLIED RESPIRATOR OR SCBA, AS REQUIRED. USE IN ACCORDANCE
WITH 29 CFR 1910.13 4 AND MANUFACTURER'S RECOMMENDATIONS.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION OR LOCAL EXHAUST TO
MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
MORE ABOUT HYDROGEN SULFIDE: AT CONCENTRATIONS ABOVE 300 PPM,
RESPIRATORY PARALYSIS, CAUSING UNCONSCIOUSNESS AND DEATH MAY OCCUR.
EPA NOTES: SARA 302/304: NONE; SARA 311: NONE/N/R; SARA 313:
DIALKYLDI THIOPHOSPHORIC ACID, ZINC SALT, CAS# 84605-29-8,
0.1-.99%; ZINC DITHIOPHOSPHATE, CAS# 25103-54-2, 0.1-0.99%
================== Physical/Chemical Properties ==================
HCC:V6
Spec Gravity:0.88
Viscosity:110 CST @ 40C
Appearance and Odor:PALE LIQUID; MINERAL OIL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID EXTREME TEMPERATURES OR EXTENDED
STORAGE PERSIODS-HYDROGEN SULFIDE MAY ACCUMULATE IN HEAD-SPACE OF
CONTAINER.
Hazardous Decomposition Products:TOXIC LEVELS OF CARBON MONOXIDE,
CARBON DIOXIDE, IRRITATING ALDEHYDES, KETONES & COMBUSTION
PRODUCTS/CMDS OF SULFUR.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS PRODUCT HAS BEEN EVALUATED FOR RCRA
CHARATERISTICS AND DOES NOT MEET THE CRITERIA OF A HAZARDOUS WASTE
IN ITS PURCHASED FORM. UNDER RCRA, IT IS THE RESPONSIBILITY OF THE
PURCHASER TO DETERMINE AT DISPOSAL, WHETHER PRODUCT MEETS RCRA
CRITERIA.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:363000 CERAMCO CERAMIC METAL GENIE-PLATINUM COLOR
CAGE:0JEB0
CAGE:0JEB0
============= Composition/Information on Ingredients =============
Ingred Name:GOLD POWDER
CAS:7400-57-5
RTECS #:MD5070000
Fraction by Wt: 45-55%
Other REC Limits:NONE RECOMMENDED
Ingred Name:PLATINUM POWDER
CAS:7440-06-4
RTECS #:TP2160000
Fraction by Wt: 40-45%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:1 MG/M3; 9596
Ingred Name:SODA LIME SILICATE
Fraction by Wt: 0-10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMMONIUM BIFLUORIDE (CERCLA)
CAS:1341-49-7
RTECS #:BQ9200000
Fraction by Wt: 0.28%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2.5 MG (F)/M3
ACGIH TLV:2.5 MG (F)/M3; 9596
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:OTHER INGREDIENTS WHICH INCLUDE
OXIDES,COLORANTS,OPAQUERS(METAL & RARE EARTH OXIDES)
Fraction by Wt: 0.05%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 >5000MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:MAY CAUSE IRRIT UPON
CONTACT.SKIN:MILD SKIN IRIRT.INHAL:AVOID BREATHING GROUND POWDER
REGULARLY.HOWEVER SHORT TERM OR ACUTE EXPO TO POWDER/DUST IS NOT
CONSIDERED SIGNIFICANT HEALTH HAZ.INGEST:NAUS EA, CRAMPS.
Explanation of Carcinogenicity:NO
Effects of Overexposure:INHAL:COUGHING, HEADACHE, VOMITING, CHEST
PAINS, CHILLS INDICATING METAL FUME FEVER WHICH MAY END IN FATAL
PULMONARY EDEMA.GOLD IS LISTED BY DANGEROUS PROPERITES OF
INDUSTRIAL MATLS AS EQUIVOCAL TUMOR GENIC AGENTS.
INGEST:NAU,CRAMPS. EYE/SKIN IRRIT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:IMMED FLUSH W/COPIOUS QUANT OF WATER FOR 15MINS.SEEK MED
ATTN IF IRRIT/DISCOMFT PERSIST.SKIN:WASH W/SOAP/WATER.INHAL:REMOVE
FROM AREA.SEEK MED ATTN.INGEST:DRINK LARGE QUANTITIES OF WHOLE MILK
ONLY , AVOID ALCOHOL.SEEK MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:NA
Autoignition Temp:Autoignition Temp Text:NP
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:EXTINGUISHER APPROVED FOR METAL FIRES.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:MAY BECOME COMBUSTIBLE IF EXPOSED TO OPEN
FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP OR SCOPP UP & STORE IN APPROPRIATE
CONTAINERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM IGN SOURCES.PROTECT
FROM HIGH HEAT.KEEP CONTAINERS CLOSED WHEN NOT IN USE.
Other Precautions:AVOID SKIN CONTACT.ECOLOGICAL INFO:STABLE,INORGANIC
COMPOUNDS,DOES NOT DEGRADE OR EVAPORATE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR MASK APPROVED FOR NUISANCE DUST.
Ventilation:GENERAL
Other Protective Equipment:EYEWASH STATION
Work Hygienic Practices:OBSERVE NORMAL CARE WHEN WORKING W/FINE
POWDERS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NA
Melt/Freeze Pt:M.P/F.P Text:N/DETERMINE
Decomp Temp:Decomp Text:NP
Vapor Pres:NP
Vapor Density:NP
Spec Gravity:18.46 G/CC
pH:NA
Viscosity:NP
Evaporation Rate & Reference:NA
Solubility in Water:NA
Appearance and Odor:FINELY DIVIDED POWDER, PLATINUM COLORED
Percent Volatiles by Volume:NP
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HALIDES,ALKALI CYANIDES,DOUBLE CYANIDES & THIOCYANIDES.
Stability Condition to Avoid:EASILY REDUCED ENVIRONEMENT.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS FOR RELATIVELY NON-TOXIC INORGANICS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:270902 STAIN & GLAZE MEDIUM
Preparer's Name:M. KRAMER
CAGE:FO558
CAGE:31976
CAGE:FO558
============= Composition/Information on Ingredients =============
Ingred Name:1,2-PROPANEDIOL (PROPYLENE GLYCOL)
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: >95%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL-RAT LD50: 20 G/KG
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: MILD TRANSIENT IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES/SKIN: MILD TRANSIENT IRRITATION.
======================= First Aid Measures =======================
First Aid:INGESTION: INDUCE VOMITING. GIVE PLENTY OF WATER. GET MED
ATT. SKIN: FLUSH W/SOAP & WATER. EYES: FLUSH W/PLENTY OF WATER FOR
AT LEAST 15 MINS.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:225F
Lower Limits:2.6%
Upper Limits:12.5%
Extinguishing Media:WATER FOG, CO2, DRY CHEMICAL, ALCOHOL FOAM
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:WASH THOROUGHLY AFTER HANDLING. DON'T
GET IN EYES, ON SKIN OR CLOTHING.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED
Ventilation:USE ADEQUATE VENTILATION
Other Protective Equipment:SAFETY SHOWER, EYE BATH
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:369F
Vapor Pres:0.05
Vapor Density:>1
Spec Gravity:1.04
Evaporation Rate & Reference:(BU AC =1): <1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIQUID, SLIGHT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAMES
Hazardous Decomposition Products:CO2, CO GASES
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE. DISPOSE OF IN ACCORDANCE W/FEDERAL,
STATE & LOCAL AUTHORITIES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:264H LIGHTWEIGHT BODY FILLER
CAGE:16522
CAGE:16522
============= Composition/Information on Ingredients =============
Ingred Name:DIETHYLENE GLYCOL, MALEIC ANHYDRIDE, PHTHALIC ANHYDRIDE
POLYMER*97-2*
CAS:26123-45-5
Fraction by Wt: <35%
Ingred Name:STYRENE, STYRENE MONOMER (SUSPECTED ANIMAL/HUMAN
CARCINOGEN BY IARC GROUP 2B) *97-2*
CAS:100-42-5
RTECS #:WL3675000
Fraction by Wt: <18%
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE (IARC - GROUP 3) *97-2*
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: <50%
OSHA PEL:2 MG/CUM (RESP DUST)
ACGIH TLV:2 MG/CUM (RESP DUST)
Ingred Name:GLASS OXIDE, FIBER GLASS WOOL, LEAD BOROSILICATE GLASS
ENAMEL FLUX
CAS:65997-17-3
Fraction by Wt: <50%
Ingred Name:VOLATILE ORGANIC CONTENT: 216 G/L
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: MAY CAUSE IRRITATION.
INHALATION: VAPORS MAY CAUSE MUCOUS MEMBRANE & UPPER RESPIRATORY
TRACT IRRITATION. REPEATED EXPOSURE TO HIGH CONCENTRATIONS OF VAPOR
MAY CAUSE LIVER & KIDNEY DAMAGE.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, DISCOMFORT.
Medical Cond Aggravated by Exposure:INDIVIDUALS W/CHRONIC RESPIRATORY
CONDITIONS (ASTHMA, CHRONIC BRONCHITIS, EMPHYSEMA).
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LARGE AMOUNTS OF WATER. SKIN: WASH THOROUGHLY
W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF
NEEDED. INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION
IN AL L CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:90F (SEE SUPP)
Lower Limits:1.1
Upper Limits:6.1
Extinguishing Media:SMALL FIRES: CO2, DRY CHEMICAL. LARGE FIRES: FOAM,
WATER FOG.
Fire Fighting Procedures:DENSE SMOKE SERIOUSLY LIMITS VISIBILITY. VENT
SMOKE & USE GAS MASK/REMOTE AIR SUPPLY. WEAR MSHA/NIOSH APPROVED
SCBA W/PROTECTIVE EQUIPMENT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION. INCREASE
VENITLATION TO MAXIMIZE VAPOR DISPERSAL. DIKE TO PREVENT RUNOOF
INTO SEWERS/WATERWAYS. MATERIAL MAY BE REMOVED BY SHOVELING,
WIPING. SWEEP/CLEAN W/INERT MATERIALS & PLACE IN CLOSED CONTAINER
FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY AREA. DON'T STORE
IN DIRECT SUNLIGHT. USE W/ADEQUATE GENERAL & LOCAL EXHAUST
VENTILATION TO MINIMIZE EXPOSURE TO VAPORS.
Other Precautions:BOND & GROUND CONTAINERS FOR TRANSFER OF PRODUCT TO
PREVENT STATIC SPARKS. AVOID PROLONGED/REPEATED CONTACT W/SKIN &
EYE CONTACT. STYRENE VAPORS ARE UNIHIBITED & MAY CAUSE BLOCKAGE OF
VENTILATION VENT S DUETO POLYMERIZATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED ORGANIC VAPOR/DUST
RESPIRATOR TO AVOID INHALATION OF EXCESSIVE AIR CONTAMINANTS.
Ventilation:LOCAL EXHAUST SHOULD BE USED TO CONTROL THE EMISSION OF AIR
CONTAMINANTS. GENERAL DILUTION MAY REDUCE AIR CONCENTRATIONS
Other Protective Equipment:SAFETY SHOWERS & EYE WASH STATIONS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. CLEAN HANDS W/SOAP & WATER AFTER EVERY USAGE.
Supplemental Safety and Health
THE PHYSICAL DATA INFORMATION IS FOR STYRENE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:293F(SUPP)
Vapor Pres:5.2(SUPP)
Vapor Density:3.6(SUPP)
Spec Gravity:1.05-1.35
Evaporation Rate & Reference:LESS THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE PASTE W/STYRENE ODOR
Percent Volatiles by Volume:18
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, PEROXIDES, OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, ELECTRICAL EQUIPMENT, SPARKS, OPEN
FLAME.
Hazardous Decomposition Products:CO, CO2, HYDROCARBONS, ORGANIC ACIDS.
Conditions to Avoid Polymerization:UNREGULATED CONTACT W/ORGANIC
PEROXIDES, EXPOSURE TO HEAT, OPEN FLAME & PROLONGED STORAGE >100F.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. IF DISCARDED, MATERIAL & CONTAINERS ARE CONSIDERED
RCRA HAZARDOUS WASTES BASED ON THE CHARACTERISTIC OF IGNITABILITY.
UN1866.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SPARTAN COTE W.B. CURE-SEAL-HARDENER
CAGE:HO841
CAGE:0KM49
CAGE:HO841
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA, LIGHT AROMATIC (PETROLEUM NAPHTHA (AROMATIC))
CAS:64742-95-6
Other REC Limits:200 PPM (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: HEADACHE. CHRONIC: NOT KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:RESULTS OF OVER EXOPSURE MAY RANGE FROM MILD
DEPRESSION TO CONVULSIONS AND LOSS OF CONSCIOUSNESS
Medical Cond Aggravated by Exposure:NOT KNOWN.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. IF BREATHING IS IRREGULAR, CALL
MD. EYE:WASH W/COPIOUS AMTS OF WATER FOR AT LEAST 15 MINUTES .
SKIN:WASH WITH A LOT OF WATER. INGEST:CALL MD.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:145F,63C
Extinguishing Media:FOAM, CO2, WATER MIST, DRY CHEMICAL
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER SPILL AND PLACE IN CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT AND OPEN FLAMES
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:APPROVED NIOSH/MSHA HYDROCARBON CANISTER TYPE
Ventilation:CONSULT LOCAL/SAFETY HEALTH AUTHORITIES IF ADDITIONAL
GUIDANCE IS NECESSARY
Other Protective Equipment:LONG LEG, LONG SLEEVE CLOTHING
Work Hygienic Practices:WASH HANDS BEFORE HANDLING FOOD
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:23.8@77F
Vapor Density:23.05GM/M3
Spec Gravity:(H20=1):O.98
Solubility in Water:NONE
Appearance and Odor:WHITE LIQUID, WITH SLIGHT PETROLEUM ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:(CONSULT FEDERAL, STATE AND LOCAL REGULATIONS):
INCINERATE OR DISPOSE OF IN APPROVED FACILITY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RTV6157B CURING AGENT.
Kit Part:Y
Preparer's Name:DA POLSINELLI
CAGE:01139
CAGE:01139
============= Composition/Information on Ingredients =============
Ingred Name:VINYLPOLYDIMETHYLSILOXANE (NON HAZARDOUS)
CAS:68083-19-2
Fraction by Wt: 60-80.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:VOC = <5 G/L
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT EST.
Ingred Name:METHYL HYDROGEN POLYSILOXANE
CAS:63148-57-2
Fraction by Wt: 10-30.0%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITATION.
======================= First Aid Measures =======================
First Aid:INGEST: RINSE MOUTH W/WATER SEVERAL TIMES. SKIN: WASH W/SOAP
& WATER. EYE: IMMED FLUSH W/PLENTY OF WATER FOR >15 MINUTES, GET
MED AID.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>250F,>121C
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:ALL STANDARD FIREFIGHTING MEDIA.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE, SCRAPE OR SOAK UP IN AN INERT MATERIAL
AND PUT IN A CONTAINER FOR DISPOSAL. WASH SURFACES WITH DETERGENT
AND WATER TO REDUCE SLIPPING HAZARD.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN ORIGINAL CONTAINER <85F. KEEP
CONTAINER CLOSED WHEN NOT IN USE. DONT REUSE CONTAINER.
============= Exposure Controls/Personal Protection =============
Other Protective Equipment:EYEWASH STATIONS.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:<500F,<260C
Vapor Pres:NEG
Vapor Density:AS AIR.
Spec Gravity:0.99
pH:NA
Evaporation Rate & Reference:NEGLIGIBLE.
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR LIQUID, W/SLIGHT ODOR.
Percent Volatiles by Volume:<1.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDIC, BASIC OR OXIDIZING AGENTS & METALLIC CATALYSTS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
SILICON DIOXIDE, FORMALDEHYDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:98-12 FLAT WHITE SPRUCE 473
CAGE:59581
CAGE:59581
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 3-5%
Other REC Limits:200 PPM
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPHORONE(SARA III)
CAS:78-59-1
RTECS #:GW7700000
Other REC Limits:5 PPM
OSHA PEL:25 PPM
ACGIH TLV:C 5 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC C8-C10 (AROMATIC
100)
CAS:64742-95-6
ACGIH TLV:100 PPM
Ingred Name:VM&P NAPHTHA (LIGROINE)
CAS:8032-32-4
RTECS #:OI6180000
Other REC Limits:STEL 400 PPM
OSHA PEL:300 PPM/400 STEL
ACGIH TLV:300 PPM; 9192
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 15-25%
Other REC Limits:100 PPM
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9192
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
CAS:75-28-5
RTECS #:TZ4300000
Other REC Limits:1000 PPM
OSHA PEL:1800 MG/CUM
ACGIH TLV:1000 PPM
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITANT. SKIN:
DEFATTING/DERMATITIS/SCALY/REDNESS/DRY/ABSORPTION. INHALATION:
RESPIRATORY SYSTEM IRRITATION/HEADACHE/DIZZINESS/NAUSEA/POSSIBLE
UNCONSCIOUSNESS/ASPHYXIATION/NOSE/THROAT IRRITATION
/NAUSEA/VOMITING/INCOORDINATION/DROWSINESS. INGESTION:
STUPER/INTOXICATION/COMA.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: CNS DEPRESSION, PERIPHERAL
POLYNEUROPATHY, COMA, NARCOSIS, ACIDOSIS, HARMFUL/FATAL, CENTRAL
NERVOUS SYSTEM & OPTIC NERVE EFFECTS. EYES: PERMANENT LOSS OF
VISION. SKIN: IRRITATION, DERMATIT IS. INGESTION: FATAL &
BLINDNESS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING STOPS, BEGIN
ARTIFICIAL RESPIRATION. EYES: FLUSH W/WATER FOR 15 MINUTES. SKIN:
WASH W/SOAP & WATER. INGESTION: UNLIKELY FROM AN AEROSOL CAN.
OBTAIN MEDICA L ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:-10F
Lower Limits:0.70%
Upper Limits:9.5%
Extinguishing Media:USE CO2, DRY CHEMICAL & FOAM
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS
KEEP FIRE-EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:EXPOSURE TO HEAT OR SUN MAY CAUSE
BURSTING.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. WIPE UP W/INERT MATERIALS &
PLACE IN APPROPRIATE CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE >120F. EXPOSURE TO HEAT OR
PROLONGED EXPOSURE TO SUN MAY CAUSE BURSTING. AVOID BREATHING
VAPORS, CONTACT W/EYES.
Other Precautions:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING
VAPORS & INHALING CONTENTS CAN BE HARMFUL OR FATAL. USE ONLY AS
DIRECTED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A SELF-CONTAINED BREATHING APPARATUS
REQUIRED FOR CONCENTRATIONS >TLV.
Ventilation:ADEQUATE VENTILATION IS SUFFICIENT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Pres:40 PSIA
Vapor Density:>AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:PAINT W/SOLVENT ODOR
Percent Volatiles by Volume: 85%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & STRONG OXIDIZING AGENTS
Stability Condition to Avoid:TEMPS >120F, SPARKS, PILOT LIGHT, OPEN
FLAME, SOURCES OF IGNITION, HEAT, & SUNLIGHT
Hazardous Decomposition Products:CO2 & CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T INCINERATE AEROSOL CAN, DISPOSE OF IN
ACCORDANCE W/LOCAL STATE & FEDERAL REGULATIONS. DON'T PLACE AEROSOL
CANS IN HOME COMPACTOR. DON'T PUNCTURE. CONSUMER COMMODITY ORM-D.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FAULT FINDER FLVOR. PENETR.(AFTER 7/82)
Kit Part:Y
CAGE:92381
CAGE:92381
============= Composition/Information on Ingredients =============
Ingred Name:PHOSPHATE ESTER
Fraction by Wt: <20%
Ingred Name:NAPHTA (PETROLEUM SPIRITS OR BENZIN)
CAS:8030-30-6
RTECS #:DE3030000
Fraction by Wt: >45%
OSHA PEL:100 PPM
Ingred Name:FLUORESCENT YELLOW DYE
Fraction by Wt: <1%.
Ingred Name:FLORESCENT WHITENING AGENT
Fraction by Wt: <1%.
Ingred Name:PROPELLENT 12/ISOBUTANE(92/8)
Fraction by Wt: 35.0%
ACGIH TLV:1000 PPM
===================== Hazards Identification =====================
Effects of Overexposure:DIZZINESS,DROWINESS, NAUSEA; LIQUID IS STRONG
SOLVENT & CAN DISSOLVE FAT FROM SKIN CAUSING IRRITAT
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR; GIVE ARTIFICAL RESPIRATION IF
NECESSARY; EYE/SKIN: WASH WITH COPIOUS AMOUNTS OF WATER. CALL A
PHYSICIAN
===================== Fire Fighting Measures =====================
Flash Point:N/A FOR AEROSOL
Extinguishing Media:CARBON DIOXIDE; DRY CHEMICAL; FOAM
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:TREAT AS CYLINDERS OF COMPRESSED GAS.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP WITH SWEEPING SPILL COMPOUNDS,OR WIPE
UP WITH RAGS
======================Handling and Storage ======================
Handling and Storage Precautions:DONOT SPRAY INTO OR AROUND OPEN FLAME
& SPARK. EXPOSURE TO TEMP. >120 F MAY CAUSE BURSTING
Other Precautions:USE ONLY AS DIRECTED: INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING VAPORS & INHALING CONTENTS CAN BE
HARMFULL OR FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RECOMMENDED
Ventilation:LOCAL EXHAUST - FOR SPRAY APPLICATION
Other Protective Equipment:AS REQUIRED BY LOCAL REQULATIONS
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:>350 F
Vapor Density:>1
Spec Gravity:1.008
Evaporation Rate & Reference:<1
Solubility in Water:NEGATIVE
Appearance and Odor:YELLOWISH WITH AROMATIC ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY SOFTEN SOME PLASTICS; RUBBERS, ORGANIC COATINGS
Stability Condition to Avoid:DONOT SPRAY INTO OPEN FLAME.
Hazardous Decomposition Products:MAY PRODUCE SOME TOXIC & IRRITATING
CMPDS; CO,CO*2, PHOSGENE
==================== Disposal Considerations ====================
Waste Disposal Methods:AEROSOL CONTAINER:DONOT PUNCTURE OR INCINERATE.
WHEN LIQUID IS ALL EXPELLED,CONTINUE TO DEPRESS BUTTON UNTIL ALL
GAS IS EXPELLED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:VVL-751 D GRADE 3
CAGE:76736
CAGE:76736
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL
CAS:64742-65-0
RTECS #:PY8038500
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:SOLVENT,DEWAXED RESIDUAL OIL (PETROLEUM)
CAS:64742-62-7
Other REC Limits:NONE SPECIFIED
Ingred Name:DISTILLATES, HEAVY PARAFFINIC
CAS:64741-51-1
RTECS #:PY8034500
Other REC Limits:NONE SPECIFIED
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:ASPHALT (PETROLEUM)
CAS:8052-42-4
RTECS #:CI9900000
Other REC Limits:NONE SPECIFIED
ACGIH TLV:5 MG/M3; (FUME);9192
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS NOT AVAILABLE
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC-SKIN:PROLONGED CONTACT
MAY CAUSE IRRITATION.INHALATION:INHALING MIST/FUMES MAY CAUSE
MUCOUS MEMBRANE IRRITATION.
Effects of Overexposure:MILD IRRITATION OF SKIN AND MUCOUS MEMBRANE
======================= First Aid Measures =======================
First Aid:GET MEDICAL AID.INHALATION:REMOVE TO FRESH AIR.EYE:FLUSH WITH
WATER FOR 15 MINUTES WHILE HOLDING EYELIDS OPEN.SKIN:WIPE OFF AND
WASH WITH SOAP AND WATER.REMOVE CONTAMINATED CLOTHING.INGESTION:DO
NOT I NDUCE VOMITING.DRINK WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:585F,307C
Lower Limits:1
Upper Limits:7
Extinguishing Media:WATER FOG (CAREFUL TO PREVENT FROTHING), CARBON
DIOXIDE, FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS WITH
ORGANIC VAPOR FILTER AND FACE SHIELD IN ENCLOSED AREAS. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:STOP FLOW. ELIMINATE IGNITION SOURCE. RECOVER
FREE PRODUCT. ADD ABSORBENT MATERIAL SUCH AS CLAY TO SPILL AREA.
SWEEP OR SCRAPE UP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY,VENTILATED AREA
AWAY FROM FLAME,HEAT & OXIDIZING AGENTS.KEEP CONTAINERS TIGHTLY
CLOSED.
Other Precautions:MINIMIZE SKIN CONTACT.WASH WITH SOAP & WATER BEFORE
EATING OR DRINKING.LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.DO
NOT GET IN EYES. AVOID INHALATION OF FUMES, VAPORS OR MIST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SHORT TERM-NON REQUIRED UNDER NORMAL
CONDITIONS.LONG DURATION EXPOSURE TO VAPORS-NIOSH APPROVED SUPPLIED
AIR RESPIRATOR, PARTICULARLY IF MATERIAL HAS BEEN HEATED.
Ventilation:LOCAL/MECHANICAL EXHAUST
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
"EMPTY" CONTAINERS MAY RETAIN RESIDUE & CAN BE DANGEROUS. DO NOT
PRESSURIZE, CUT, WELD, BRAZE, SOLDER DRILL, GRIND OR EXPOSE SUCH
CONTAINERS TO HEAT, FLAME, SPARKS OR OTHER SOURCES OF IGNITION.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:750F,399C
Vapor Pres:<0.01
Vapor Density:>5
Spec Gravity:0.930
Evaporation Rate & Reference:<0.01 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DARK BROWN LIQUID, BLAND PETROLEUM ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
Stability Condition to Avoid:HIGH TEMPERATURE AND FLAMES
Hazardous Decomposition Products:OXIDES OF CARBON
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN AN APPROPRIATE DISPOSAL FACILITY
IN COMPLIANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:JET MELT ADHESIVE 3792-PG
CAGE:76381
DIV
CAGE:52152
CAGE:76381
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE-VINYL ACETATE COPOLYMER
(ACETIC ACID ETHENYL ESTER, POLYMER W/ETHENE) *96-3*
CAS:24937-78-8
Fraction by Wt: 60-70%
Ingred Name:HYDROCARBONS, C6-20, POLYMERS, HYDROGENATED (HYDROCARBON RE
IN) *96-3*
CAS:69430-35-9
Fraction by Wt: 30-40%
Ingred Name:TETRAKIS (METHYLENE) 3,5-DI-TERT-BUTYL-4-HYDROXYHYDROCIN
*96-3*
CAS:6683-19-8
Fraction by Wt: 0.5-5%
Ingred Name:VINYL ACETATE
CAS:108-05-4
RTECS #:AK0875000
Other REC Limits:10 PPM
ACGIH TLV:35 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MAY CAUSE IRRITATION. SKIN:
BURNS FROM CONTACT W/MOLTEN MATERIAL. MILD IRRITATION/BLISTERS.
INHALATION: IRRITATION TO UPPER RESPIRATORY. INGESTION: MAY CAUSE
IRRITATION OF GASTROINTESTINAL TISSU ES.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, REDNESS, SWELLING, PAIN, TEARING,
BURNS, SORENESS, COUGHING, SNEEZING, VOMITING, ABDOMINAL
TENDERNESS, NAUSEA, BLOOD IN VOMITUS, BLOOD IN FECES
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/LARGE AMOUNTS OF WATER. SKIN:
IMMEDIATELY FLUSH W/LARGE AMOUNTS OF WATER & COVER W/A CLEAN
DRESSING. DON'T ATTEMPT TO REMOVE ADHESIVE. INHALATION: REMOVE TO
FRESH AIR. INGEST ION: DON'T INDUCE VOMITING. DRINK 2 GLASSES OF
WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>450F
Extinguishing Media:WATER SPRAY, CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING W/HELMET, SCBA
W/POSITIVE PRESSURE/PRESSURE DEMAND, BUNKER COAT/PANTS, BANDS
AROUND ARMS/WAIST/LEGS, FACE MASK & HEAD COVERING.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:COLLECT MATERIAL. OBSERVE PRECAUTIONS FROM
OTHER SECTIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN.
Other Precautions:AVOID EYE CONTACT W/VAPOR, SPRAY/MIST. AVOID SKIN
CONTACT W/HOT ADHESIVE & APPLICATOR TIP. AVOID PROLONGED BREATHING
OF VAPORS. DON'T INGEST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:REQUIRED
Ventilation:PROVIDE APPROPRIATE LOCAL EXHAUST FOR MOLTN/EXTRUDED
MATERIAL. USE IN A WELL VENTILATED AREA.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:0.97
Solubility in Water:INSOLUBLE
Appearance and Odor:WAXY SOLID, WHITE OPAQUE, SOLID ADHESIVE IN RODS,
ODORLESS
Percent Volatiles by Volume:0/WT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO, CO2, TOXIC VAPORS,
GASES/PARTICULATES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE PRODUCT IN A SANITARY LANDFILL
IN ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:190 0984 GBX DEVELOPER AND REPLENISHER
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 60-65% %
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM SULFITE
CAS:10117-38-1
RTECS #:WT3530000
Fraction by Wt: 5-10% %
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIETHYLENE GLYCOL
CAS:111-46-6
RTECS #:ID5950000
Fraction by Wt: 5-10% %
Other REC Limits:NONE RECOMMENDED
Ingred Name:HYDROQUINONE (SARA 302/313) (CERCLA)
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: 8% %
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9596
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SODIUM SULFITE
CAS:7757-83-7
RTECS #:WE2150000
Fraction by Wt: 5-10% %
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): NOT GIVEN
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. CAUSES EYE IRRITATION. CAUSES SKIN
IRRITATION. MAY CAUSE ALLERGIC SKIN REACTION. HARMFUL IF SWALLOWED.
CAN CAUSE KIDNEY DAMAGE. MAY CAU SE IRRITATION OF THE
GASTROINTESTINAL TRACT.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION, SKIN IRRITATION, ALLERGIC SKIN
REACTION, KIDNEY DAMAGE, GI TRACT IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMEEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: INDUCE VOMITING AS DIRECTED BY MEDICAL PERSONNEL. NEVER
GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. CALL MD OR POISON
CONTROL IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL
FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY PRODUCE
HAZARDOUS DECOMPOSTION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER IF ALLOWABLE WITH LARGE AMOUNTS
OF WATER. OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT
MATERIAL, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN
SURFACE TO REMOVE RESIDUA L CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH EYES, SKIN AND
CLOTHING. USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER
HANDLING. KEEP FROM CONTACT WITH OXIDIZING MATERIALS.
Other Precautions:THE ROUTINE USE OF A NONALKALINE (ACID) TYPE OF HAND
CLEANER AND REGULAR CLEANING OF WORKING SURFACES WILL HELP MINIMIZE
THE POSSIBILITY OF A SKIN REACTION. KEEP CONTAINER TIGHTLY CLOSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.249
pH:10.2
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIQUID, NO ODOR
Percent Volatiles by Volume:70%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF SULFUR
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. MAY REQUIRE NEUTRALIZATION IF PH
< 2.0 OR PH > 12.5. DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE ANDLOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PR-1764 ADHESION PROMOTER
Kit Part:Y
Preparer's Name:JCS
CAGE:DO563
CAGE:83574
CAGE:DO563
============= Composition/Information on Ingredients =============
Ingred Name:TETRAOCTYL TITANATE (TOT)
CAS:1070-10-6
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
Ingred Name:AROMATIC NAPHTHA (NAPHTHA)
CAS:68477-31-6
Fraction by Wt: 50%
Other REC Limits:NONE SPECIFIED
Ingred Name:ETHYL ACETATE
CAS:141-78-6
RTECS #:AH5425000
Fraction by Wt: 20%
Other REC Limits:NONE SPECIFIED
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-BUTANONE (METHYL ETHYL KETONE) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 20%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM;STEL 300 PPM
ACGIH TLV:200 PPM;STEL 300 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-PROPANOL (ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:400 PPM;STEL 500 PPM
ACGIH TLV:400 PPM;STEL 500 PPM
Ingred Name:VOC: 802 G/L (TESTED PER EPA METHOD 24)
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: LIQUID CAN CAUSE SEVERE
IRRITATION. SKIN: LOCAL IRRITATION. MAY CAUSE ALLERGIC SKIN RASH IN
SENSITIZED INDIVIDUALS. INHALATION: IRRITATION OF THE RESPIRATORY
TRACT. MAY CAUSE HEADACHE, DIZZINESS , UNCONSCIOUSNESS. INGESTION:
MAY CAUSENAUSEA, VOMITING, LIVER, KIDNEY DAMAGE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LUKEWARM WATER FOR 15 MINUTES. IF SYMPTOMS
PERSIST, CONSULT PHYSICIAN. SKIN: WASH WITH SOAP AND WATER. IF
SYMPTOMS ARE PRESENT CONSULT A PHYSICIAN. INGESTION: DO NOT INDUCE
VOMITING. CONSULT A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:23.0F,-5.0C
Lower Limits:1.8
Upper Limits:11.4 (MEK)
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:USE AIR SUPPLIED RESPIRATOR. USE WATER TO COOL
HEAT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:HIGH TEMPERATURES MAY CAUSE PRESSURE
BUILDUP IN CLOSED CONTAINERS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. WEAR AIR SUPPLIED
RESPIRATOR FOR MAJOR UNVENTILATED SPILL. COVER WITH ABSORBENT.
SCOOP INTO CONTAINERS.
======================Handling and Storage ======================
Other Precautions:THIS PRODUCT CONTAINS A TOXIC CHEMICAL OR CHEMICALS
SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF TITLE III
OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 AND 40
CFR PART 372.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN SPRAYING, APPLYING IN CONFINED AREAS, OR IN
OTHER CIRCUMSTANCES LIKELY TO PRODUCE AIRBORNE LEVELS OF SOLVENT IN
EXCESS OF PEL, USE AN ORGANIC VAPOR CARTRIDGE RESPIRATOR OR AIR
SUPPLIED RESPIRATOR .
Ventilation:GENERAL VENT TO MAINTAIN VAPOR BELOW PEL.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:0.82
Evaporation Rate & Reference:4.6 (MEK)
Solubility in Water:MODERATE
Appearance and Odor:BLUE LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:EPA WASTE NO: D001 AND D035. DISPOSE OF SPILLAGE
IN COMPLIANCE WITH FEDERAL AND STATE REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SELECTRON ZINC-NICKEL LHE SOLUTION,PAS 5970
CAGE:11924
CAGE:11924
============= Composition/Information on Ingredients =============
Ingred Name:ZINC SULFATE (SARA 313) (CERCLA)
CAS:7733-02-0
RTECS #:ZH5260000
Fraction by Wt: <34%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SODIUM HYDROXIDE (CERCLA)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:NICKEL SULFATE (SARA 313) (CERCLA)
CAS:7786-81-4
RTECS #:QR9350000
Fraction by Wt: <10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG(NI)/M3
ACGIH TLV:0.1 MG(NI)/M3; 9596
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:AMMONIUM HYDROXIDE (CERCLA)
CAS:1336-21-6
RTECS #:BQ9625000
Fraction by Wt: <39%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER (NON-HAZARDOUS INGREDIENTS AND/OR WATER)
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: <16%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY &
GI TRACTS. ACUTE- EYE CONTACT MAY CAUSE IRRITATION. PROLONGED SKIN
CONTACT MAY CAUSE DERMATITIS. INHALATION OF VAPORS/MISTS MAY CAUSE
RESPIRATORY TRACT IRRITATIO N. HARMFUL IF SWALLOWED. MAY CAUSE
ABDOMINAL DISCOMFORT. CHRONIC- FUMES MAY CAUSE RESPIRATORY DISEASE
& TISSUE DAMAGE.
Explanation of Carcinogenicity:CONTAINS NICKEL.
Effects of Overexposure:IRRITATION, REDNESS, NAUSEA, VOMITING, TEARING,
DERMATITIS
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION MAY BE
MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:CALL PHYSICIAN IF SYMPTOMS PERSIST. EYE:IMMEDIATELY FLUSH
WITH WATER FOR 15 MINUTES. HOLD EYELIDS OPEN. SKIN:FLUSH WITH COLD
WATER. INHALED:REMOVE TO FRESH AIR. PROVIDE CPR/OXYGEN IF NEEDED.
ORAL:IF C ONSCIOUS, DRINK WATER & INDUCE VOMITING. CALL A
PHYSICIAN/POISON CONTROL CENTER IMMEDIATELY. NEVER GIVE FLUID OR
INDUCE VOMITING IF PATIENT IS UNCONSCIOUS OR HAS CONVULSIONS.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NOT RELEVANT
Upper Limits:NOT RELEVANT
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. EVACUATE PERSONNEL TO A SAFE
AREA.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR PROTECTIVE EQUIPMENT.
VENTILATE AREA. ABSORB ON SAND, VERMICULITE OR SIMILAR MATERIAL.
SWEEP UP AND PLACE IN AN APPROPRIATE CONTAINER. HOLD FOR DISPOSAL.
WASH CONTAMINATED SPILL AR EA WITH SOAPY WATER, THEN WATER TO
REMOVE RESIDUES
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN TIGHTLY CLOSED CONTAINER AWAY
FROM STRONG MINERAL ACIDS.
Other Precautions:WASH THOROUGHLY WITH SOAP AND WATER AFTER HANDLING
AND BEFORE EATING, DRINKING, SMOKING. KEEP OUT OF REACH OF
CHILDREN. DO NOT TAKE INTERNALLY. AVOID EYE AND SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY NEEDED. IF WORKING IN CONFINED
AREAS, IF EXCESSIVE MISTING IS EXPECTED OR IF EXPOSURE MAY OR DOES
EXCEED RECOMMENDED PERMISSIBLE EXPOSURE LIMITS, WEAR NIOSH-APPROVED
RESPIRATOR (REFER TO 29 CFR 1910.134)
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP VAPOR,
FUME OR DUST LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER, PROTECTIVE
CLOTHING
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:B3
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:1.26
pH:8.8
Solubility in Water:COMPLETE
Appearance and Odor:BLUISH-GREEN COLORED SOLUTION; AMMONIA ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG MINERAL ACIDS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:OXIDES OF SULFUR AND AMMONIA FUMES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. RECYLING IS RECOMMENDED. KEEP OUT OF
SEWERS, STORM DRAINS AND SURFACE WATERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:4565 BONDING LIQUID
CAGE:52751
CAGE:52751
============= Composition/Information on Ingredients =============
Ingred Name:ING 20:MATL MUST BE CONDUCTED IN COMPLIANCE WITH ALL
APPLICABLE FEDERAL, STATE, AND LOCAL REGULATIONS.
RTECS #:9999999ZZ
Ingred Name:OTHER PROT EQUIP: SHOWERS @ ANY LOCATION WHERE SKIN CONT
CAN OCCUR. HAVE EYE BATHS READILY AVAIL WHERE CONT CAN OCCUR.
RTECS #:9999999ZZ
Ingred Name:ING 6:LIDS SHOULD BE HELD AWAY FROM EYEBALL TO ENSURE
THOROUGH RINSING. GET MED ATTN IF IRRIT PERSISTS. INHAL: (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:REMOVE FROM SOURCE OF EXPOS. IF NOT BRTHG, INSTITUTE
CARDIOPULM RESUSCITATION. IF BRTHG IS DFCLT, GIVE (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:O*2. KEEP AFFECTED PERSON WARM & @ REST. GET IMMED
MED ATTN.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: RELATED TO CHEM, CONT CHEMTREC (800/424-9300) &
YOUR LOC FIRE DEPT. NOTIFY NATL RESPONSE CTR, IF (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:REQD. KEEP UNNEC PEOPLE AWAY. STAY UPWIND; KEEP OUT
OF LOW AREAS. ISOLATE HAZ AREA & DENY ENTRY. (ALSO (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:SEE PERSONAL PROT INFO SECTION). ISOLATE FOR 1/2
MILE IN ALL DIREC IF TANK/TANKCAR IS INVOLVED IN FIRE. (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:NO FLARES, SMOKING OR FLAMES IN HAZ AREA. STOP LEAK
IF YOU CAN DO IT W/OUT RISK. USE H*2O SPRAY TO (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:REDUCE VAP. SM SPILLS: TAKE UP W/SAND/OTHER
NONCOMBUST ABSORB MATL/OTHER ABSORB KNOWN TO BE COMPATIBLE; (ING
15)
RTECS #:9999999ZZ
Ingred Name:ING 14:THEN FLUSH AREA W/H*2O. LG SPILLS:DIKE FAR AHEAD OF
SPILL FOR LATER DISP. NOTIFICATION: REPORTABLE QTY (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:FOR MATL IS 1,000 LBS, BASED ON 100% STYRENE
MONOMER. ANY SPILL OR OTHER REL, OR SUBSTANTIAL THREAT OF (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:REL OF MATL TO AIR, H*2O, OR LAND (UNLESS ENTIRELY
CNTND IN WORKPLACE) EQUAL TO/IN EXCESS OF REPORTABLE (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:QTY MUST BE RPTD IMMED TO NATL RESPONSE CTR
(800/424-9300) AS REQD BY U.S.FED LAW. FAILURE TO RPT MAY (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:RESULT IN CRIMINAL PENALTIES.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH:POLYESTER RESIN SOLIDS ARE NON-HAZ SOLID
WASTES. TRANSPORTATION, STOR, TRTMT, & DISP OF WASTE (ING 21)
RTECS #:9999999ZZ
Ingred Name:STYRENE
CAS:100-42-5
RTECS #:WL3675000
Fraction by Wt: 25-50%
OSHA PEL:100 PPM
ACGIH TLV:S,50PPM/100STEL;9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:UNSATURATED POLYESTER RESIN (PREPOLYMER)
Fraction by Wt: 50-75%
Ingred Name:NON HAZARDOUS INGREDIENTS; (REMAINING COMPONENTS NOT
DETERMINED HAZ &/OR HAZ COMPONENTS PRESENT @ <1.0%)
Fraction by Wt: TRACE
Ingred Name:EFTS OF OVEREXP: IRRIT OF MATL MAKE INHAL OF ACUTELY TOX
CONC UNLIKELY. MAY CAUSE ADVERSE REPROD EFTS, BASED ON (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:TESTS WITH ANIMALS. MUTAGENIC IN BACTERIAL AND
MAMMALIAN TEST SYSTEMS.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:PROPERTIES. GET MED ATTN IF IRRIT PERSISTS.
EYE: FLUSH IMMED W/LG AMTS OF H*2O FOR @ LST 15 MIN. (ING 7)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INGEST:MOD TOX. MAY CAUSE GI DISTURB.
SYMP MAY INCL IRRIT, NAUS, VOMIT & DIARR. SKIN:MOD IRRITATING.
RPTD/RPLNG SKIN CONT MAY CAUSE REDDEN, INFLAMM/BLISTER. MAY CAUSE
ALLERGIC RXN IN SOME INDIVIDUALS. CONT W/HEATED MATL MAY CAUSE
THERMAL BURNS. EYES: MOD IRRITATING. DIRECT CONT MAY CAUSE TEMP
CORNEAL, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:STYRENE: GROUP 2B(IARC).
Effects of Overexposure:HLTH HAZ: LESIONS, CONT W/HEATED MATL MAY CAUSE
THERMAL BURNS. INHAL:SLIGHTLY TOX. MAY CAUSE RESP TRACT IRRIT. MAY
CAUSE HARMFUL CNS EFTS. EFTS MAY INCL DROW, IMPAIRED BALANCE, NAUS,
VOMIT, LOSS OF AP PETITE & GEN WEAKNESS-"STYRENE SICKNESS". MAY
ALSO CAUSE BLOOD CHANGES & LIVER DAM. DISAGREEABLE ODOR & (ING 4)
Medical Cond Aggravated by Exposure:PRE-EXISTING MED CNDTNS WHICH MAY
BE AGGRAVATED BY EXPOS INCL, BUT ARE NOT LIMITED TO, CHRONIC RESP &
SKIN DISEASE & CENTRAL NERVOUS SYSTEM DISORDERS.
======================= First Aid Measures =======================
First Aid:INGEST: DO NOT INDUCE VOMIT BECAUSE OF DANGER OF ASPIRATING
LIQ INTO LUNGS. IF SPONTANEOUS VOMIT OCCURS, MONITOR FOR BRTHG
DFCLTY. KEEP WARM & @ REST. GET IMMED MED ATTN. SKIN:WASH AREA OF
CONT THOROW/SOAP/H2O. REMOVE CONTAMD CLTHG IMMED.PLACE CONTAMD
CLTHG IN CLSD CONTR FOR STOR UNTIL LAUNDERED OR DISCARDED. IF CLTHG
IS TO BE LAUNDERED, INFORM PERSON PERFORMING OPERATIONS OF CONTAM
HAZ (ING 6)
===================== Fire Fighting Measures =====================
Flash Point:>87F,>30C
Lower Limits:1.1%
Upper Limits:6.1%
Extinguishing Media:USE DRY CHEM, ALL PURPOSE/POLAR TYPE AFFF FOAM/H2O
SPRAY TO EXTING FIRE.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
H2O/FOAM MAY CAUSE FROTH, W/FURTHER APPLICATN LEADING TO BOILOVER.
FOAM MAY HAVE LIM EFTIVNESS (SUPP DATA)
Unusual Fire/Explosion Hazard:FIRE MAY PRDCE POISONOUS/IRRITATING GAS,
FUMES/VAP. EXCESS HEAT MAY TRIGGER POLYMERIZATION OF CONFINED MATL.
CNTRS MAY EXPLODE IN HEAT OF FIRE. (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:IF YOUR FACILITY/OPERATION HAS AN "OIL OR HAZ
SUBSTANCE CONTINGENCY PLAN", ACTIVATE ITS PROC. TAKE IMMED STEPS TO
STOP & CNTN SPILL. CAUTION SHOULD BE EXERCISED REGARDING PERS SFTY
& EXPOS TO SPILLEDMATL. FOR TECH ADVICE & ASSISTANCE (ING10)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN TIGHTLY CLSD CONTRS IN COOL,
DRY, ISOLATED, WELL-VENTILATED AREA AWAY FROM HEAT, SOURCES OF
IGNIT & INCOMPATIBLES.
Other Precautions:EMPTY CONTRS MAY CNTN TOX, FLAMM/COMBUSTIBLE OR
EXPLOSIVE RESIDUE OR VAPORS. DO NOT CUT, GRIND, DRILL, WELD OR
REUSE CONTAINERS UNLESS ADEQ PRECAUTIONS ARE TAKEN AGAINST THESE
HAZARDS. DO NOT WEAR CON TACT LENSES WHEN WORKING W/SUBSTANCE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED EQUIPMENT WHEN AIRBORNE
EXPOS LIM ARE EXCEEDED, NIOSH/MSHA APPROVED BRTHG EQUIP MAY BE REQD
FOR NON-ROUTINE & EMER USE. VENT MAY BE USED TO CTRL OR REDUCE
AIRBORNE CONC.
Ventilation:VENT MAY BE USED TO CONTROL OR REDUCE AIRBORNE
CONCENTRATIONS.
Other Protective Equipment:PROT CLTHG TO PVNT SKIN CONT. SUGGESTED PROT
MATLS ARE: POLYVINYL ALCOHOL, POLYETHYLENE & VITON. PROVIDE SFTY
(ING 22)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC: ON 3 DIMENSIONAL FIRES. USE H2O SPRAY TO COOL
FIRE-EXPOS CONTRS, STRUCTURES & TO PROT PERS. USE H2O TO FLUSH
SPILLS AWAY FROM SOURCES OF IGNIT. DO NOT FLUSH DOWN PUBLIC SEWERS.
EXPLO HAZ: STYRENE VAP ARE UNINHIBITED & MAY FORM POLYMERS IN
VENT/ FLAME STOR TANKS, RSLTG IN STOPPAGE OF VENTS.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:>293F,>145C
Melt/Freeze Pt:M.P/F.P Text:-0.5F,-31C
Vapor Pres:<50@68F
Vapor Density:3.6
Spec Gravity:1.12
Evaporation Rate & Reference:<1(BUTYL ACETATE=1)
Solubility in Water:SLIGHT
Appearance and Odor:COLORLESS TO YELLOWISH, VERY REFRACTIVE, OILY
LIQUID W/A SWEET, AROMATIC ODOR.
Percent Volatiles by Volume:28-50
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCTS MAY BE
HAZARDOUS. REACTS VIGOROUSLY WITH OXIDIZING AGENTS.
Conditions to Avoid Polymerization:EXCESSIVE HEAT.
==================== Disposal Considerations ====================
Waste Disposal Methods:POLYESTER RESINS, WHEN DISCARDED/DISPOSED OF,
ARE NOT SPECIFICALLY LISTED AS HAZ WASTE IN FED REGS. POLYESTER
RESIN IN LIQ ST IS HAZ WASTE BECAUSE IT EXHIBITS CHARACTERISTIC OF
IGNITABILITY (40CFR261) . COMPLETELY POLYMERIZED, FULLY-CURED (ING
20)
| 1 | gloves_mandatory |
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.