text
stringlengths 542
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:F6306 AZROCK CLEAR THIN SPREAD ADHESIVE
CAGE:22112
CAGE:22112
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Ingred Name:LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA, LACOLENE
CAS:64742-89-8
Fraction by Wt: 1-5%
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:VOLATILE ORGANIC CONTENT: 63.6 G/L;LESS WATER 111.5 G/L
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED EXPOSURE TO HIGH
CONCENTRATION OF VAPORS MAY EFFECT THE NERVOUS SYSTEM.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:PROLONGED EXPOSURE TO HIGH CONCENTRATION OF
VAPORS MAY EFFECT THE NERVOUS SYSTEM.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LARGE AMOUNTS OF WATER FOR 20 MINS. SKIN: WASH
W/SOAP & WATER. INHALATION: MOVE TO FRESH AIR. GIVE CPR IF NOT
BREATHING. INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, CO2, CHEMICAL &/WATER SPRAY.
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT INCLUDING SCBA.
Unusual Fire/Explosion Hazard:CAN PRODUCE CO & CO2, FORMALDEHYDE &
OTHER UNIDENTIFIED ORGANIC PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. CONTAIN BY DIKING
W/SOIL/OTHER NONCOMBUSTIBLE ABSORBENT & PUT INTO APPROVED
CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM INCOMPATIBLE
MATERIALS. STORE AT ROOM TEMP. DON'T REFRIGERATE. FREEZE-TRAW
STABLE TO 0F.
Other Precautions:USE IN WELL VENTILATED AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED WHEN USED IN A WELL VENTILATED
AREA. IF NOT, USE AN APPROVED MASK W/CARTRIDGE FOR ORGANIC VAPORS.
Ventilation:ADEQUATE
Other Protective Equipment:SAFETY STATION RECOMMENDED W/FIRST AID
WORKER.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>200F
Spec Gravity:1
Solubility in Water:COMPLETE
Appearance and Odor:BEIGE PASTE W/SLIGHT WOOD ODOR
Percent Volatiles by Volume:50
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EAL ARCTIC 46, 601070-00
CAGE:3U728
CAGE:3U728
============= Composition/Information on Ingredients =============
Ingred Name:SYNTHETIC ESTERS
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ADDITIVES
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUP DAT: APPLIC LAWS & REGS, & PROD CHARACTERISTICS AT TIME
OF DISP. PVNT SPILLS FROM ENTERING STORM SEWERS (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3: OR DRAINS AND CONTACT WITH SOIL.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH: ANY GOVERNMENT APPRVD WASTE DISP FACILITY.
USE OF THESE METHS IS SUBJECT TO USER COMPLIANCE W/ (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: APPLIC LAWS & REGS & CONSIDERATION OF PROD
CHARACTERISTICS AT TIME OF DISP. THIS MATL IS EXPECTED TO BE (ING
7)
RTECS #:9999999ZZ
Ingred Name:ING 6: INHERENTLY BIODEGRADABLE, BUT NOT READILY
BIODEGRADABLE AS DEFINED BY THE OECD CRITERIA. DISPOSE OF IN (ING
8)
RTECS #:9999999ZZ
Ingred Name:ING 7: ACCORDANCE WITH LOCAL, STATE, AND FEDERAL
REGULATIONS .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT): > 2000 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INGESTION/SKIN: PRACTICALLY
NON-TOXIC, BASED ON TESTING OF SIMILAR PRODUCTS AND/OR THE
COMPONENTS. EYES/SKIN: PRACTICALLY NON-IRRITATING, BASED ON TESTING
OF SIMILAR PRODUCTS AND/OR THE COMPONE NTS. CHRONIC: NONE SPECIFIED
BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH THORO W/WATER FOR AT LEAST 15 MIN. IF IRRITATION
OCCURS, CALL MD. SKIN: WASH CONTACT AREAS W/SOAP & WATER. INHAL:
REMOVE FROM FURTHER EXPOSURE. IF RESPIRATORY IRRIT, DIZZINESS,
NAUSEA/UNCO NSCIOUSNESS OCCURS, SEEK IMMED MED ASSIST & CALL MD. IF
BREATHING HAS STOPPED, USE MOUTH-TO-MOUTH RESUSCITATION. INGEST:
NOT EXPECTED TO BE A PROBLEM WHEN INGESTED. IF UNCOMFORTABLE SEEK
MED ASSIST.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:428F,220C
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL AND WATER
FOG.
Fire Fighting Procedures:WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER/FOAM MAY CAUSE FROTHING. USE WATER TO KEEP FIRE-EXPOSED
CONTRS COOL. WATER SPRAY MAY BE USED TO (SUP DAT)
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:RPT SPILLS AS REQUIRED TO APPROP AUTH. U.S.
COAST GUARD REGS REQUIRE IMMED REPORTING OF SPILLS THAT COULD REACH
ANY WATERWAY INCL INTERMITTENT DRY CREEKS. RPT SPILL TO COAST GUARD
TOLL FREE # (800) 42 4-8802. IN CASE OF ACCIDENT/ROAD SPILL (SUP
DAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:THIS MATL IS NOT INTENDED FOR USE IN
AIR COMPRESSORS FOR BREATHING APPLICATIONS. NO SPECIAL PRECAUTIONS
ARE NEC BEYOND NORM GOOD HYGIENE PRACTICES.
Other Precautions:DO NOT STORE IN OPEN OR UNLABELLED CONTAINERS. STORE
AWAY FROM STRONG OXIDIZING AGENTS OR COMBUSTIBLE MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL REQUIREMENTS UNDER ORDINARY
CONDITIONS OF USE AND WITH ADEQATE VENTILATION. USE NIOSH APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:USE IN WELL VENTILATED AREA.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:GOOD PERSONAL HYGIENE PRACTICES SHOULD ALWAYS
BE FOLLOWED.
Supplemental Safety and Health
FIRE FIGHT PROC: FLUSH SPILLS AWAY FROM EXPOS. PVNT RUNOFF FROM FIRE
CTL/DILUTION FROM ENTERING STREAMS, SEWERS/DRINKING WATER SUPPLY.
SPILL PROC: NOTIFY CHEMTREC (800) 424-9300. ABSORB ON FIRE RETARD
ANT TREATED SAWDUST, DIATOMACEOUS EARTH, ETC. SHOVEL UP & DISP OF
AT APPROP WASTE DISP FACILITY I/A/W CURRENT (ING 3)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>601F,>316C
Vapor Pres:<0.1 @ 20C
Spec Gravity:0.98
Solubility in Water:NEGLIGIBLE
Appearance and Odor:STRAW COLORED LIQUID, WITH MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:EXTREME HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:PROD IS SUITABLE FOR BURNING IN ENCLSD,
CONTROLLED BURNER FOR FUEL VALUE/DISP BY SUPERVISED INCIN. SUCH
BURNING MAY BE LIMITED PURSUANT TO RCRA. IN ADDN, THE PROD IS
SUITABLE FOR PROCESSING BY APPRVD RECYCLING FACILITY/CAN BE
DISPOSED OF AT (ING 5)
| 1 | gloves_mandatory |
=======================================================
NIIN: 01-373-8844
Product ID: FORMULA #104A,
Cage: OFTT5
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: OFTT5
Assigned Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: OFTT5
Cage: 1A864
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: CLEANING COMPOUND,SOLVENT-DETERGENT
Unit of Issue: DR
Quantitative Expression: 00000000055GL
UI Container Qty: 1
Type of Container: PLASTIC
=======================================================
Ingredients
=======================================================
Cas: 5131-66-8
% Wt: <8.0
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Signs And Symptions Of Overexposure: CHRONIC CONTACT W/SKIN MAY CAUSE
DEFATTING, REDNESS, IRRITATION.
Medical Cond Aggravated By Exposure: UNKNOWN
First Aid: SKIN/CLOTHES: WASH W/SOAP & WATER. WASH CLOTHES BEFORE REUSE.
EYES: FLUSH W/WATER 15 MIN. CALL DR/OPTHALMOLOGIST IMMED. INGESTION: GIVE
LARGE AMOUNTS WATER/MILK. GET IMMEDIATE MED AID.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: PICK UP SPILL W/ABSORBENT MATERIAL & SWEEP UP.
FLUSH AREA W/WATER. CAUTION: FLOORS MAY BE SLIPPERY. TAKE CARE TO AVOID
FALLS.
Waste Disposal Methods: IN ACCORDANCE W/FEDERAL, STATE, LOCAL REGULATIONS.
Handling And Storage Precautions: KEEP AWAY FROM CHILDREN!
Other Precautions: NA
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: >212F,>100C
Extinguishing Media: WATER SPRAY OR FOG, DRY CHEMICAL, CO2 OR ALCOHOL FOAM IF
PRODUCT INVOLVED IN FIRE.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA WHERE PRODUCT INVOLVED
IN FIRE. KEEP FIRE-EXPOSED CONTAINERS COOL W/WATER SPRAY TO PREVENT BURSTING.
Unusual Fire/Explosion Hazard: THIS PRODUCT WILL NOT BURN. EXTREME HEAT MAY
CAUSE BURSTING OF CONTAINER AND DECOMPOSITION OF MATERIAL.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE W/NORMAL VENTILATION
Ventilation: NA
Other Protective Equipment: NA
Work Hygienic Practices: USE GOOD PERSONAL HYGIENE. WASH HANDS AFTER HANDLING,
BEFORE EATING.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >212F,>100C
M.P/F.P Text: NOT EST.
Vapor Pres: 20
Vapor Density: 1.0
Spec Gravity: 1.105
PH: 8.0
Viscosity: WATER-LIKE
Evaporation Rate & Reference: 1 (WATER=1)
Solubility in Water: COMPLETE
Appearance and Odor: CLEAR, GREEN COLORED LIQUID, PLEASANT ODOR
Corrosion Rate: NA
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NA
Materials To Avoid: NA
Hazardous Decomposition Products: NORMAL COMBUSTION PRODUCTS FROM BURNING,
CARBON DIOXIDE & CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 130311
Product ID: FORMULA #104A,
Review Date: 05/14/1996
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: DR
Container QTY: 1
Type Of Container: PLASTIC
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: FORMULA #104A,
Cage: OFTT5
Assigned IND: Y
Company Name: LHB INDUSTRIES
Street: 8833 FLEISCHER PLACE
Zipcode: 63134
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: NK
CHRONIC CONTACT W/SKIN MAY CAUSE DEFATTING,
REDNESS, IRRITATION.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TECHNI PLUS ACS BASECOAT HARDENER
Kit Part:Y
CAGE:KCHCR
CAGE:KCHCR
============= Composition/Information on Ingredients =============
Ingred Name:MODIFIED CYCLOALIPHATIC AMINE
Fraction by Wt: >50%
Ingred Name:TRIETHYLENETETRAMINE; (ALIPHATIC AMINE)
CAS:112-24-3
RTECS #:YE6650000
Fraction by Wt: <10%
Ingred Name:MUSCOVITE; (FILLER)
CAS:1318-94-1
Fraction by Wt: >20%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION AND SENSITIZATION.
INGESTION: IRRITATION OF MUCOUS MEMBRANES IF SWALLOWED. INHALATION:
IRRITATION OF RESPIRATORY TRACT. EYE: STRONG IRRITANT AND CAN CAUSE
BURNS.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN: WASH AFFECTED AREA WITH LARGE AMOUNTS OF WATER AND
SOAP. WASH CONTAMINATED CLOTHES BEFORE REUSE. GET MEDICAL
ATTENTION. INGESTION: GIVE TWO GLASSES OF WATER TO A CONSCIOUS
PERSON. DO NOT INDUCE VOMITING. GET MEDICAL ATTENTION. INHALATION:
REMOVE VICTIM TO FRESH AIR AND PROVIDE OXYGEN IF NOT BREATHING. GET
MEDICAL ATTENTION. EYE: FLUSH WITH WATER FOR AT LEAST 15 MINUTES.
GET MEDICAL AID.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F,>93C
Extinguishing Media:WATER, CARBON DIOXIDE, FOAM OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . REMOVE FIRE EXPOSED DRUMS AND COOL WITH
WATER.
Unusual Fire/Explosion Hazard:MAY PRODUCE HAZARDOUS FUMES OR HAZARDOUS
DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:USE DRY MATERIAL TO ABSORB MATERIAL; WEAR
APPROPRIATE PROTECTIVE EQUIPMENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE NEAR OXIDIZING AGENTS.
STORE IN COOL, DRY AREA. RECOM MAX STORAGE TEMP 100F. TYPICAL SHELF
LIFE: INDEFINITE IN TIGHTLY SEALED CNTNRS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED ORGANIC VAPOR CANISTER
RESPIRATOR IF VAPORS IN HIGHER CONCENTRATIONS ARE PRESENT.
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:ADEQUATE CLOTHING AND EYEWASH STATION.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:1.17 25C/77F
Solubility in Water:SLIGHTLY MISCIBLE
Appearance and Odor:BEIGE, VISCOUS LIQUID. AMMONIA-LIKE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS.
Stability Condition to Avoid:DO NOT STORE NEAR PEROXIDES, STRONG ACIDS
OR OXIDIZING AGENTS. STORE OUT OF DIRECT SUNLIGHT.
Hazardous Decomposition Products:DECOMPOSITION MAY PRODUCE FUMES,
SMOKE, OXIDES OF CARBON AND/OR HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF PROPERLY IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FLAT BLACK EPOXY MPC-1082
CAGE:079G1
CAGE:079G1
============= Composition/Information on Ingredients =============
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: <5.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:XYLENES (SARA 313) (CERCLA) (VP = 5.1 @ 58F
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 56.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:MINERAL SPIRITS (VP = 2 @ 68F
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: <0.5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:METHYL ETHYL KETOXIME (VP = 4 @ 68F
CAS:96-29-7
RTECS #:EL9275000
Fraction by Wt: <0.5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:VOC = 4.66 LBS/GL
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: IRRITATION, DIZZINESS,
HEAEACHE, LOSS OF COORDINATION, FATIGUE. EYE: IRRITATION, REDNESS,
TEARING. SKIN: REDNESS, BURNING, DRYING, CRACKING, ABSORPTION.
INGEST: IRRITATION, VOMITING, DIARRHEA, LOSS OF APPETITE.
Medical Cond Aggravated by Exposure:RESPIRATORY & SOME ALLERGIES.
======================= First Aid Measures =======================
First Aid:CALL DR. INGEST: DRINK 1-2 GLASSES WATER/MILK. DONT INDUCE
VOMIT. GIVE 1-2 TABLESPOONS VEGETABLE OIL. IF DROWSY/UNCONSCIOUS,
PLAE ON LEFT SIDE W/HEAD DOWN. INHAL: GET FRESH AIR. GIVE OXYGEN IF
BREATHI NG IS DIFFICULT. GIVE ARTIFICIAL RESPIRATION IF NOT
BREATHING. KEEP WARM/QUIET. EYES: FLUSH W/WATER FOR 15 MINUTES,
LIFT LIDS. SKIN: REMOVE CONTAM CLOTHES/SHOES, FLUSH W/WATER. WASH
W/SOAP & WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:80.0F,26.7C
Lower Limits:1.0
Upper Limits:7.0
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER, FOG.
Fire Fighting Procedures:WEAR APPROPRIATE PROTECTIVE EQUIPMENT. MOVE
UNDAMAGED CONTAINER FROM FIRE AREA. DONT DIRECT STREAM OF WATER
INTO FIRE. COOL FIRE EXPOSED CNTNR W/WATER/EVAC AREA
Unusual Fire/Explosion Hazard:KEEP CONTAINER TIGHTLY CLOSED. ISOLATE
FROM IGNITS. CLOSED CONTAINER MAY EXPLODE W/EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:EVAC AREA. ELIMINATE IGNITION SOURCES. VENT
AREA. ABSORB. DO NOT FLUSH AREA W/WATER. NOTIFY APPROPRIATE
AUTHORITIES IMMEDIATELY.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNR TIGHTLY CLSD. STORE IN
COOL, DRY WELL VENTED AREA AWAY FROM IGNITS. POST NO SMOKING SIGNS.
STORE IN APPROVED CNTNR. PROT CNTNR FROM DAMAGE.
Other Precautions:DONT PRESSURIZE/CUT/WELD/BRAISE/DRILL/GRIND ON/NEAR
CONTAINER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE GAS MASK W/APROPRIATE CARTRIDGES &
CANISTERS. NIOSH APPROVED.
Ventilation:LOCAL EXHAUST RECOMMENDED.
Other Protective Equipment:EYEWASH STATION, IMPERVIOUS CLOTHING.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:282 TO 318F
Vapor Pres:<AIR
Spec Gravity:1.0
Evaporation Rate & Reference:<ETHER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT/SPARKS/OPEN FLAME.
Hazardous Decomposition Products:CO2, CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE W/FEDERAL/STATE/LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FAST WIPES HEAVY DUTY CLEANING TOWELS, 6298
Resp. Party Other MSDS Num.:6215FAST
Preparer's Name:DONALD H SINNER
CAGE:02905
CAGE:02905
CAGE:6M644
============= Composition/Information on Ingredients =============
Ingred Name:ALCOHOL; (DENATURED ALCOHOL)
CAS:64-17-5
RTECS #:KQ6300000
Minumum % Wt:1.
Maxumum % Wt:10.
OSHA PEL:1900 MG/M3;1000 PPM
ACGIH TLV:1880 MG/M3;1000 PPM
Ingred Name:D-LIMONENE
CAS:5989-27-5
RTECS #:GW6360000
Minumum % Wt:.5
Maxumum % Wt:5.
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MAY CAUSE EYE IRRITATION.
INHALATION: PROLONGED OR REPEATED OVEREXPOSURE MAY CAUSE DIZZINESS,
GIDDINESS OR NAUSEA.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:EYES: DO NOT RUB EYES. IMMEDIATELY FLUSH EYES THOROUGHLY WITH
WATER FOR AT LEAST 15 MINUTES, IF CONDITION WORSENS OR IRRITATION
PERSISTS, CONTACT A PHYSICIAN. INHALATION: EVACUATE PEOPLE AND MOVE
TO F RESH AIR. CONTACT A PHYSICIAN IN CASE OF SYMPTOMS OR ILLINESS.
SKIN: FLUSH WITH COPIOUS AMOUNTS OF WATER. CALL MD . INGEST: CALL
MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>93.9C, 201.F
Extinguishing Media:WATER FOG, ALCOHOL FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP WITH ABSORBENT MATERIAL. CONTAIN AND
PICK UP WITH MATERIALS. PUT IN A SEALED APPROVED CONTAINER. FLUSH
AREA WITH WATER TO REDUCE SLIPPING HAZARDS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF EYES. DO NOT TAKE
INTERNALLY. STORE IN SEALED CONTAINERS IN A COOL PLACE.
Other Precautions:KEEP OUT OF REACH OF CHILDREN! KEEP FROM FREEZING.
AVOID EXCESSIVE HEAT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED WHEN USED AS DIRECTED. USE NIOSH
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
.
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . NOT REQUIRED WHEN USED AS DIRECTED.
Work Hygienic Practices:GOOD HOUSEKEEPING AND PERSONAL CARE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:=93.3C, 200.F
Melt/Freeze Pt:=-3.9C, 25.F
Vapor Pres:25 (MM HG)
Vapor Density:0.7(AIR=1)
Spec Gravity:1 (H*2O=1)
pH:9 (UNDILUTED)
Viscosity:1-100 CPS (LIQUID)
Solubility in Water:>95%
Appearance and Odor:TOWELETTE WITH ORANGE FRAGRANCED LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:ACCORDING TO APPLICABLE LOCAL, STATE AND FEDERAL
REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:SHIPPING REGULATIONS CLASS: NOT DOT REGULATED.
===================== Regulatory Information =====================
SARA Title III Information:OSHA STANDARDS AND SARA TITLE III DO NOT
APPLY TO THIS COSMETIC PRODUCT. COSMETICS AND UNLISTED INGREDIENTS
ARE NOT CONSIDERED HAZARDOUS OR REPORTABLE BY ANY FEDERAL (OSHA,
WHMIS, SARA, ECRA, RCRA), A NY STATE OR ANY OTHER RIGHT TO KNOWN
REGULATIONS.
======================= Other Information =======================
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:UNIVERSAL GREASE, R-103
Preparer's Name:A. SELLECK
CAGE:28002
CAGE:28002
CAGE:RXGPR
============= Composition/Information on Ingredients =============
Ingred Name:ARISTONATE 500; (BENZENE SULFONIC ACID, MIXED MONO- AND
DI-C15-30-ALKYL DERIVATIVES, SODIUM SALT)
CAS:78330-12-8
Fraction by Wt: 8%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MIXTURE CONTAINING INGREDIENTS 3-5
RTECS #:9999999ZZ
Fraction by Wt: 3%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL PETROLEUM DISTILLATES, HYDROTREATED (SEVERE)
LIGHT NAPHTHENIC; (HYDROTREATED LIGHT NAPHTHENIC (ING 4)
CAS:64742-53-6
RTECS #:PY8036001
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:ING 3: DISTILLATE, PETROLEUM)
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED (SEVERE),
HEAVY NAPHTHENIC; (HYDROTREATED HEAVY NAPHTHENIC (ING 6)
CAS:64742-52-5
RTECS #:PY8035001
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ING 5: DISTILLATE, PETROLEUM)
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BENZENE, C14-30-ALKYL DERIVATIVES
CAS:68855-24-3
RTECS #:CY2270000
Fraction by Wt: 3%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN CONTACT: MAY BE IRRITATING TO
SKIN IF PROLONGED OR REPEATED EXPOSURE OCCURS. EYE CONTACT: MAY
CAUSE EYE IRRITATION. INHALATION: INHALATION IS NOT LIKELY TO OCCUR
UNDER NORMAL CONDITIONS OF USE. I NHALATION OF MISTS OR HEATED
VAPORS MAYCAUSE IRRITATION OF THE NOSE AND THROAT. INGESTION: MAY
CAUSE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: VOMITING, DIARRHEA AND NAUSEA.
CHRONIC EFFECTS: NONE KNOWN.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN: WASH AFFECTED AREAS W/SOAP & WATER. REMOVE CONTAMD
CLTHG & LAUNDER BEFORE REUSE. EYES: FLUSH EYES, INCLUDING UNDER
EYELID, W/GENEROUS AMOUNTS OF WATER FOR AT LEAST 15 MIN. GET MED
ATTN. INHAL: M OVE TO FRESH AIR. AID IN BRTHG IF NECESSARY & GET
MED ATTN. INGEST: DO NOT INDUCE VOMITING. IF VOMITING OCCURS
SPONTANEOUSLY, KEEP HEAD BELOW HIPS TO AVOID ASPIRATION OF LIQUID
INTO THE LUNGS.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:300F,149C
Extinguishing Media:FOAM, ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP . USE
STD FIRE FIGHTING TECHNIQUES FOR FIRES INVOLVING PETRO PRODS. DO
NOT USE WATER EXCEPT AS FOG TO COOL CNTNRS.
Unusual Fire/Explosion Hazard:CONTAINERS MAY LEAK CONTENTS IF EXPOSED
TO HEAT OF FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA. COLLECT SPILL IN ABSORB MATL &
TRANSFER TO STEEL DRUMS. DO NOT FLUSH TO SEWER. THIS PROD IS
CLASSIFIED AS AN OIL UNDER SECTION 311 OF CLEAN WATER ACT. SPILLS
ENTERING (A) SURF WATERS OR (B) ANY WATERCOURSE OR SEWER ENTERING
OR (SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:READ AND FOLLOW ALL LABEL DIRECTIONS
AND CAUTIONS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL PROTECTION REQUIRED. USE NIOSH
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:GENERAL (MECHANICAL) VENTILATION IS SUFFICIENT.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPILL PROC: LEADING TO SURFACE WATERS THAT CAUSE A SHEEN MUST BE
REPORTED TO NRC, 800-424-8802.
================== Physical/Chemical Properties ==================
Vapor Pres:0.01 @ 20C
Vapor Density:>1
Spec Gravity:0.9
VOC Grams/Liter:.06
Evaporation Rate & Reference:VERY SLOW
Solubility in Water:NEGLIGIBLE
Appearance and Odor:SOFT, YELLOW GREASE; PETROLEUM-TYPE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
KEEP AWAY FROM STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:DO NOT USE NEAR FLAMES OR HEAT SOURCE.
Hazardous Decomposition Products:COMBUSTION YIELDS UNDEFINED ORGANICS
AND OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR BURY SATURATED ABSORBENT IN
LANDFILL. RECYCLE IF POSSIBLE. DISPOSE OF IN ACCORDANCE WITH ALL
FEDERAL, STATE AND LOCAL REGULATIONS. EMPTY CONTAINERS MAY BE
DISPOSED OF AS NORMAL REFUSE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LITHIUM POWER CELL, 3 VOLT-U3VL
CAGE:JO511
CAGE:0UU59
CAGE:JO511
============= Composition/Information on Ingredients =============
Ingred Name:MANGANESE DIOXIDE
CAS:1313-13-9
RTECS #:OP0350000
Fraction by Wt: 12-15%
OSHA PEL:5 MG MN/M3 CEILING
ACGIH TLV:5 MG MN/M3
Ingred Name:LITHIUM (METAL)
CAS:7439-93-2
RTECS #:OJ5540000
Fraction by Wt: 2-3%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CARBONIC ACID, CYCLIC PROPYLENE ESTER; (PROPYLENE
CARBONATE)
CAS:108-32-7
RTECS #:FF9650000
Fraction by Wt: 7-8%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:1,3-DIOXOLANE
CAS:646-06-0
RTECS #:JH6760000
Fraction by Wt: 6-7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:LITHIUM HEXAFLUOROARSENATE
CAS:29935-35-1
Fraction by Wt: 2-3%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUP DAT: BY VENTILATION TO AN IGNITION SOURCE AND FLASH
BACK.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: IMMED FLUSH W/PLENTY OF WATER FOR AT LEAST
15 MIN & GET MED ATTN. EYES: IMMED FLUSH W/PLENTY OF (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: WATER FOR AT LEAST 15 MIN & GET IMMED MED ATTN.
INHAL: REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE OXYGEN OR (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: ARTIFICIAL RESPIRATION) . INGESTION: CALL MD
IMMEDIATELY .
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: BATTERY CHARGING: BATTERIES ARE NOT DESIGNED TO
BE RECHARGED. CHARGING MAY RSLT IN ELECTROLYTE (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: LEAKAGE &/CAUSE BATTERY TO FLAME. BATTERY
DISASSEMBLY: NEVER DISASSEMBLE. SHOULD BATTERY UNINTENTIONALLY(ING
12)
RTECS #:9999999ZZ
Other REC Limits:NONE RECOMMENDED
MUST BE USED TO HANDLE ALL BATTERY COMPONENTS. AVOID (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: INHAL OF ANY VAPS THAT MAY BE EMITTED. IN THE EVENT
OF SKIN/EYE EXPOS TO ELECTROLYTE, REFER TO FIRST AID(ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: SECTION. BATTERY SHORT CIRCUIT: MORE THAN A
MOMENTARY SHORT CIRCUIT WILL GEN REDUCE BATTERY SERVICE (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: LIFE. EXTENDED SHORT CIRCUITING CREATES HIGH TEMPS
IN CELL. HIGH TEMPS CAN CAUSE SKIN BURNS/CAUSE CELL (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: TO FLAME. AVOID REVERSING BATTERY POLARITY W/IN
BATTERY ASSEMBLY. TO DO SO MAY CAUSE CELL TO FLAME/LEAK.(ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: MIXED BATTERIES & TYPES: THE USE OF OLD & NEW
BATTERIES/BATTERIES OF VARYING SIZES & TYPES IN THE SAME (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17: BATTERY ASSEMBLY SHOULD BE AVOIDED. BATTERIES' ELEC
CHARACTS & CAPABILITIES VARY & DMG MAY RSLT TO (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: BATTERIES OR ELECTRICAL EQUIPMENT.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC: NONE SPECIFIED BY
MANUFACTURER. NEVER DISASSEMBLE A BATTERY.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:ELECTROLYTE CONT: SKIN: IMMED FLUSH W/PLENTY OF WATER FOR AT
LEAST 15 MIN. IF SYMPS ARE PRESENT AFTER FLUSHING, GET MED ATTN.
EYES: IMMED FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN & GET MED
ATTN. IN HAL: REMOVE TO FRESH AIR. SUPPORT BRTHG(GIVE OXYGEN/ARTF
RESP) . INGEST: CALL MD IMMED . LITHIUM METAL CONT: SKIN: REMOVE
PARTICLES OF LITHIUM FROM SKIN AS RAPIDLY AS POSS. (ING 7)
===================== Fire Fighting Measures =====================
Extinguishing Media:COPIOUS AMTS OF COLD WATER IS AN EFFECTIVE EXTING
MEDIUM FOR LITHIUM BATTERIES. DO NOT USE WARM WATER/HOT (SUP DAT)
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIP . DURING WATER APPLICATIONS, CAUTION IS ADVISED AS BURNING
PIECES OF LIGHITUM MAY BE EJECTED FROM FIRE.
Unusual Fire/Explosion Hazard:BATTERIES MAY FLAME/LEAK POTENTIALLY HAZ
ORG VAPS IF EXPOSED TO EXCESS HEAT/FIRE. FIRE/EXCESS HEAT MAY PRDCE
HAZ DECOMP PRODS. DAMAGED/OPENED BATTERIES(SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:MAY LEAK &/FLAME IF OPENED, RECHARGED,
CONNECTED IMPROPERLY/DISP OF IN FIRE. DO NOT STORE IN A MANNER THAT
ALLOWS TERMINALS TO SHORT CIRCUIT.
Other Precautions:STORE IN COOL (<70F), DRY AREA THAT IS SUBJECT TO
LITTLE TEMP CHANGE. DO NOT PLACE NEAR HEATING EQUIP, NOR EXPOSE TO
DIRECT SUNLIGHT FOR LONG PERIODS. ELEVATED TEMPS CAN RSLT IN
REDUCED BATTERY SERVIC E LIFE. (ING 10)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXTING MEDIA: WATER. LITH-X (CLASS D EXTING MEDIA) IS EFFECTIVE ON
FIRES INVOLVING ONLY A FEW CELLS. DO NOT USE CARBON DIOXIDE/HALON
TYPE EXTING. DRY CHEM TYPE EXTING HAVE LIMITED EXTING POTENTIAL. EX
PLO HAZ: CAN RSLT IN RAPID HEATING & RELEASE OF FLAM VAPS. VAPS ARE
HVR/AIR & MAY TRAVEL ALONG GROUND/BE MOVED (ING 6)
================== Physical/Chemical Properties ==================
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:BATTERY MUST BE COMPLETELY DISCHARGED PRIOR TO
DISP &/TERMINALS MUST BE TAPED/CAPPED TO PVNT SHORT CIRCUIT. DISP
BY INCIN/BURIAL AT PERMITTED WASTE TREATMENT &/DISP SITE. DISP OF
LGE QTYS OF LITHIUM P OWER CELLS MAY BE SUBJECT TO FED, STATE/LOC
REGS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EUAB030A MIL-C-85285B TYPE I/II C-35237 BLUE PART A
Kit Part:Y
Preparer's Name:JIM SCHMIDT
CAGE:0ULT0
CAGE:0ULT0
============= Composition/Information on Ingredients =============
Ingred Name:CATALYST AMORPHOUS SILICA, DI-ME SILOXANES & SILICONES
*97-1*
CAS:67762-90-7
Fraction by Wt: <10%
OSHA PEL:6 MG/CUM (DUST)
ACGIH TLV:5 MG/CUM (DUST)
Ingred Name:HEXONE, METHYL ISOBUTYL KETONE (MIBK), 4-METHYL-2-PENTANONE
*97-1*
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: <10%
Other REC Limits:50 PPM
OSHA PEL:100 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
CARCINOGEN, IARC GROUP 3)*97-1*
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: <25%
OSHA PEL:15 MG/CUM (DUST)
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:2-HEPTANONE, METHYL N-AMYL KETONE *97-1*
CAS:110-43-0
RTECS #:MJ5075000
Fraction by Wt: <10%
Other REC Limits:50 PPM
OSHA PEL:100 PPM
ACGIH TLV:50 PPM
Ingred Name:METHYL ETHYL KETONE, 2-BUTANONE *97-1*
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: <10%
Other REC Limits:590 MG/CUM
OSHA PEL:200 PPM
ACGIH TLV:200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2,4-PENTANEDIONE, ACETYLACETONE
*97-1*
CAS:123-54-6
RTECS #:SA1925000
Fraction by Wt: <10%
ACGIH TLV:20 PPM
Ingred Name:BUTYL ACETATE (N-BUTYL ACETATE) *97-1*
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: <10%
Other REC Limits:150 PPM
OSHA PEL:150 PPM
ACGIH TLV:150 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE (SUSP ANIMAL CARC BY IARC; NTP)* 97-1 *
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: <10%
OSHA PEL:2 MG/CUM (RESP DUST)
ACGIH TLV:2 MG/CUM (RESP DUST)
Ingred Name:CRYSTALLINE-QUARTZ SILICA, SILICA DUST (SUSPECTED HUMAN
CARCINOGEN BY IARC-GROUP 2A; SUSPECTED CARCINOGEN NTP) *97-1*
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 0.54%
Other REC Limits:0.05 MG/CUM (NIOSH)
OSHA PEL:0.1 MG/CUM RESP DUST
ACGIH TLV:0.1 MG/CUM RESP DUST
Ingred Name:BARIUM SULFATE, BARYTES *97-1*
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: <50%
OSHA PEL:10 MG/CUM (DUST)
ACGIH TLV:10 MG/CUM (DUST)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:CRYSTALLINE SILICA-PROLONGED
OVEREXPOSURE BY INHALATION CAUSES SILICOSIS, SEVERE & PERMANENT
PULMONARY FIBROSIS. SPRAY MIST/VAPORS OF SPRAY PAINTS CAUSES
IRRITATION TO EYES, NOSE, THROAT, UPPER RESPIR ATORY TRACT, MUCOUS
MEMBRANES & SKIN. REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS
CAUSES PERMANENT BRAIN/NERVOUS (SUPP)
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, SHORTNESS OF BREATH, ALLERGIC
RESPIRATORY REACTION.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/COPIOUS AMOUNTS OF LUKEWARM WATER FOR 15
MINS. INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING IF
REQUIRED. INGESTION: RINSE MOUTH IMMEDIATELY. GIVE 6-8 OUNCES OF
LIQUID. NEVER G IVE ANYTHING BY MOUTH TO AN UNCONSCIOUSPERSON.
DON'T INDUCE VOMITING UNLESS DIRECTED TO BY A PHYSICIAN. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:23F
Lower Limits:1
Upper Limits:11.4
Extinguishing Media:CO2, DRY CHEMICAL, ALCOHOL FOAM.
Fire Fighting Procedures:EVACUATE AREA. DON'T ENTER CONFINED SPACE W/O
APPROVED POSITIVE PRESSURE SCBA. (SEE SUPP)
Unusual Fire/Explosion Hazard:LIQUID & VAPORS ARE DANGEROUS FIRE HAZARD
& MODERATE EXPLOSION HAZARD WHEN EXPOSED TO HEAT, FLAME/ANY
IGNITION SOURCE. VAPORS >AIR, MAY TRAVEL TO (SEE SUPP)
================== Accidental Release Measures ==================
Spill Release Procedures:STAY UPWIND & AWAY FROM MATERIAL UNLESS
WEARING APPROPRIATE PROTECTIVE EQUIPMENT. SAFELY STOP &/CONTAIN
DISCHARGE. REMOVE IGNITION SOURCES. VENTILATE AREA. USE
NON-SPARKING TOOLS FOR CLEANUP. COVER W/ INERT MATERIAL TO REDUCE
FUMES. (SEE SUPP)
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS COOL, DRY & AWAY FROM
IGNITION SOURCES. USE & STORE W/ADEQUATE VENTILATION. KEEP
CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE.
Other Precautions:DON'T SMOKE IN STORAGE AREAS. AVOID INHALATION OF
VAPORS/MISTS. AVOID PERSONAL CONTACT. EMPTY CONTAINERS ARE
HAZARDOUS DUE TO PRODUCT RESIDUES. DON'T FLAME CUT/WELD EMPTY
DRUMS. INTENTIONAL MISUSE BY CONCENTRATING/INHALING IS
HARMFUL/FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED HALF-MASK RESPIRATOR
W/ORGANIC VAPOR CARTRIDGE WHERE EXCESSIVE EXPOSURE TO VAPORS/MIST
MAY OCCUR.
Ventilation:AS REQUIRED TO CONTROL VAPOR/DUST/MIST CONCENTRATION.
SHOWERS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
SPECIAL FIRE: FIGHT FIRE FROM SAFE DISTANCE/PROTECTED LOCATION. USE
WATER TO COOL FIRE EXPOSED CONTAINERS. UNUSUAL FIRE: DISTANT
IGNITION SOURCE & FLASH BACK. CONTAINERS MAY RUPTURE IF EXPOSED TO
EXTR EME HEAT. HEALTH HAZARDS: SYSTEM DAMAGE. SPILLS: DON'T
FLUSH/KEEP OUT OF SEWERS, DRAINS, WATERSHED/WATERWAYS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:175-301F
Vapor Density:>1
VOC Grams/Liter:2.8
Evaporation Rate & Reference:FASTER THAN BU AC
Solubility in Water:INSOLUBLE
Appearance and Odor:BLUE LIQUID W/MODERATE KETONE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CRYSTALLINE SILICA-HYDROFLUORIC ACID.
Stability Condition to Avoid:EXTREME HEAT, SPARKS, OPEN FLAME, HOT
SURFACES & OTHER IGNITION SOURCES.
Hazardous Decomposition Products:IN PRESENCE OF AIR: OXIDES OF CARBON &
VARIOUS HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TT-E-509C ALKYD ENAMEL SG Y60, B509TB
Preparer's Name:PATRICIA SHAW
CAGE:3Z268
CAGE:3Z268
============= Composition/Information on Ingredients =============
Ingred Name:HYDROCARBON MIXTURE (VAPOR PRESSURE 2.0 MM HG @ 68 F)
CAS:64741-41-9
Fraction by Wt: 20%
Other REC Limits:NONE SPECIFIED
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:PETROLEUM HYDROCARBON (VAPOR PRESSURE 50.0 MM HG @ 0 F)
CAS:8008-20-6
RTECS #:OA5500000
Fraction by Wt: 5%
Other REC Limits:100 PPM
OSHA PEL:500 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: NASAL, RESP IRRIT, NARCOSIS
(CNTRL NERV SYS DEPRESS). EYE: SEVERE IRRIT. SKIN: MOD IRRIT,
DEFATTING, DERMATITIS. INGEST: DIGEST TRACT IRRIT, CNTRL NERV SYS
DEPRESS. ASPIRATION HZD-MAT'L ENTERS LUNG DURING
SWALLOW/VOMIT-CAUSE LUNG INFLAMM. CHRONIC: CENTRL NERV
SYS/RESP/LUNG/EYE/SKIN/GI/LIVER/SPLEEN/KIDNEY DAMAGE.
Effects of Overexposure:INHAL: DIZZINESS, WEAKNESS, FATIGUE, NAUSEA,
HEADACHE. EYE: TEARING, REDNESS, BLURRED VISION.
Medical Cond Aggravated by Exposure:RESPIRATORY TRACT IRRITATION,
DERMATITIS, NAUSEA.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/WATER 15 MIN, LIFTING EYELIDS. GET MED AID.
SKIN: REMOVE CONTAMINATED CLOTHES, WASH W/SOAP & WATER. IF IRRIT
PERSISTS, SEE DR. INHAL: REMOVE TO FRESH AIR. APPLY ARTIF RESP OR
ADMINISTER O XYGEN IF NEEDED. CONSULT DR. INGEST: GIVE WATER/MILK
DIRECTED TO DO SO BY MED PERSONNEL. IF MED ADVICE UNAVAIL, TAKE TO
NEAREST EMERG HOSP.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:104F,40C
Lower Limits:0.7
Upper Limits:6.1
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:EXTINGUISHERS FOR NFPA FLAMMABLE LIQUID FIRES.
WATER MAY BE INEFFECTIVE, USE AS FOG TO COOL EXPOSED CNTNRS. WEAR
FULL PROTECTIVE CLOTHING & BREATHING APP.
Unusual Fire/Explosion Hazard:VAPOR FORM EXPLOSIVE MIXTURE WITH AIR
(LEL TO UEL), CAN BE IGNITED BY MANY SOURCES. CLOSED CNTNRS MAY
EXPLODE W/HEAT. ISOLATE FROM ELECTRIC EQUIP, SPARK, FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE
ALL IGNITION SOURCES. VENTILATE THE AREA. PROVIDE APPROPRIATE
PROTECTIVE EQUIPMENT. DIKE AROUND THE SPILL AREA. COVER SPILL WITH
INERT ABSORBENT AND TRANSF ER USING NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 80 F IN (ORIGINAL) CLOSED
CNTNR. AVOID FLAME & HIGH TEMPERATURES. DO NOT STORE NEAR OXIDIZING
AGENTS OR ACIDS.
Other Precautions:VAPOR IS HEAVIER THAN AIR & MAY TRAVEL DISTANCE TO
SOURCE OF IGNITION & FLASHBACK. DON'T INGEST, AVOID BREATHING
HEATED VAPOR/ MIST. KEEP AWAY FROM HEAT. GROUND ALL CONNECTIONS,
CONTAINERS, ETC WHEN P OURING/TRANSFERING. USE NON-SPARK TOOLS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA EQUIP WHEN AIRBORN EXPOSURE
LIMITS EXCEEDED. CONSULT RESPIRATOR MFR TO DETERMINE EQUIP FOR
GIVEN APPLICATION. HIGH AIRBORN CONCENTRATIONS MAY REQUIRE USE OF A
SUPPLIED-AIR RESPIRATOR ORSELF-CONTAINED BREATHING APPARATUS.
Ventilation:PROVIDE SUFFICIENT VENT TO CONTROL EXPOSURE LEVELS BELOW
TLV/ PEL. VENTILATION MUST BE EXPLOSION PROOF.
Other Protective Equipment:WEAR IMPERMEABLE APRONS & PROTECT CLOTHING
WHEN POSSIBLE TO PREVENT SKIN EXPOSURE. USE HEAD CAPS WHEN
POSSIBLE.
Work Hygienic Practices:AFTER USING, WASH BEFORE EATING, TOILETING OR
SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:315 TO 335F
Vapor Density:> AIR.
Spec Gravity:1.4 (WATER=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NOT WATER SOLUBLE
Appearance and Odor:PIGMENTED LIQUID. SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:DO NOT EXPOSE TO HEAT OR IGNITION SOURCES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
DIOXIDE AND/OR MONOXIDE, LOW MOLECULAR WEIGHT HYDROCARBONS AND
ORGANIC ACIDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP OUT OF DRAINS, SEWERS AND WATERWAYS.
DISPOSE OF PRODUCT IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS. IGNITABLE D001, TOXIC D005.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:92-65150-1 QUICKSILVER EXHAUST TUBE SEALER KIT, PART A
Kit Part:Y
CAGE:GO139
CAGE:88907
CAGE:GO139
============= Composition/Information on Ingredients =============
Ingred Name:WEIGHT PER GALLON IN POUNDS: 9.7
RTECS #:9999999WG
Ingred Name:EPOXY RESIN
Fraction by Wt: >10%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: IRRITATION &
SENSITIZER.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION. SKIN: IRRITATION &
SENSITIZER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS. SKIN:
WASH THOROUGHLY W/SOAP & WATER. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>200F
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEMICAL OR CO2
Fire Fighting Procedures:USE STANDARD FIRE FIGHTING PROCEDURES. WEAR
SELF-CONTAINED BREATHING APPARATUS.
================== Accidental Release Measures ==================
MATERIAL. RESIDUE MAY BE REMOVED W/CHLORINATED SOLVENT.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID SKIN CONTACT W/PRODUCT AT ALL
TIMES. STORE IN A COOL, DRY PLACE. KEEP OUT OF REACH OF CHILDREN.
AVOID CONTACT W/EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS REQUIRED.
Ventilation:MECHANICAL (GENERAL): STANDARD.
Other Protective Equipment:IMPERVIOUS CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Appearance and Odor:LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:OPEN FLAME
Hazardous Decomposition Products:LOW MOLECULAR WEIGHT HYDROCARBONS & CO
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR DISPOSE OF IN AN APPROVED
INDUSTRIAL LANDFILL, CONSULT YOUR STATE OR LOCAL AUTHORITIES IN THE
EVENT MORE RESTRICTIVE REQUIREMENTS APPLY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HASTELLOY W (ERNIMO-3)
CAGE:0ACE2
CAGE:0ACE2
============= Composition/Information on Ingredients =============
Ingred Name:COBALT (SARA III)
CAS:7440-48-4
RTECS #:GF8750000
Fraction by Wt: 2.5% MAX
OSHA PEL:0.1 MG/M3;AS CO
ACGIH TLV:0.05 MG/M3;DUST 9293
Ingred Name:CHROMIUM (SARA III)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 4.0-6.0%
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:IRON OXIDE
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 4.0-7.0%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 1.0% MAX
Other REC Limits:1.0MG/M3(FUME),ACGIH
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
Fraction by Wt: 23-26%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9293
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 63.0%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: 1.0% MAX
Other REC Limits:5.0MG/M3;RESP. DUST
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:VANADIUM (SARA III)
CAS:7440-62-2
RTECS #:YW1355000
Fraction by Wt: 0.6% MAX
Other REC Limits:ABOVE FIG.FOR V*2O*5
OSHA PEL:C,0.5 MG V2O5/M3 RD
ACGIH TLV:0.05 MG V205/M3;9293
Ingred Name:GRAPHITE, SYNTHETIC
CAS:7440-44-0
RTECS #:FF5250100
Fraction by Wt: 0.12%MAX
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9293
Ingred Name:SULFUR
CAS:7704-34-9
RTECS #:WS4250000
Fraction by Wt: 0.03%MAX
OSHA PEL:13MG/M3 (SO*2)
ACGIH TLV:5MG/M3 (SO*2)
Ingred Name:PHOSPHORUS
CAS:7723-14-0
RTECS #:TH3495000
Fraction by Wt: 0.04%MAX
OSHA PEL:0.1MG/M3 (YELLOW)
ACGIH TLV:0.1MG/M3 (YELLOW)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:GRAPHITE, NATURAL
CAS:7782-42-5
RTECS #:MD9659600
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MPPCF RDUST
ACGIH TLV:2 MG/M3 RDUST; 9293
Ingred Name:BARIUM CARBONATE
CAS:513-77-9
RTECS #:CQ8600000
Other REC Limits:NONE SPECIFIED
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:CALCIUM CARBONATE (MARBLE) (LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9192
Ingred Name:CALCIUM FLUORIDE
CAS:7789-75-5
RTECS #:EW1760000
Other REC Limits:NONE SPECIFIED
OSHA PEL:2.5 MG/M3 AS F
ACGIH TLV:2.5 MG/M3 AS F
Ingred Name:SODIUM FLUOALUMINATE (SYN: SODIUM ALUMINUM FLUORIDE)
CAS:15096-52-3
RTECS #:WA9625000
Other REC Limits:NONE SPECIFIED
OSHA PEL:2.5 MG/M3 AS F
ACGIH TLV:2.5 MG/M3 AS F
Ingred Name:POTASSIUM ALUMINUM SILICATE (FELDSPAR)
CAS:68476-25-5
Other REC Limits:NONE SPECIFIED
ACGIH TLV:2 MG/M3
Ingred Name:CHROMIUM OXIDE
CAS:1308-38-9
RTECS #:GB6475000
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.5 MG(CR)/M3
ACGIH TLV:0.5 MG(CR)/M3 9192
Ingred Name:POTASSIUM SILICATE
CAS:1312-76-1
Other REC Limits:NONE SPECIFIED
Ingred Name:SODIUM SILICATE
CAS:1344-09-8
Other REC Limits:NONE SPECIFIED
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
Other REC Limits:NONE SPECIFIED
OSHA PEL:C, 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE:METALLIC TASTE,NAUSEA,CHEST
TIGHTNESS,FEVER,DIZZINESS,DRYNESS,EYES,NOSE,THROAT
IRRITATION,ALLERGIC SKIN REACTIONS,IRRITATION & DERMATITIS.
CHRONIC:BRONCHIAL ASTHMA,LUNG FIBROSIS,PNEUMOCONIOSIS.L UNG
CANCER(CR & NI EXPOSURE),CNS DEPRESSION(MN EXPOSURE),GI
DISORDERS(FE EXPOSURE).
Explanation of Carcinogenicity:CHROMIUM VI IS A HUMAN
CARCINOGEN.CHROMIUM III IS A SUSPECTED HUMAN CARCINOGEN.NICKEL IS A
SUSPECTED HUMAN CARCINOGEN.
Effects of Overexposure:EYES, SKIN, RESPIRATORY TRACT AND
GASTROINTESTINAL IRRITATION. METALLIC TASTE, NAUSEA, CHEST
TIGHTNESS, COUGH, FEVER, DIZZINESS.
Medical Cond Aggravated by Exposure:AGGRAVATION OF EXISTING RESPIRATORY
OR ALLERGIC CONDITIONS.HIGHER LEVEL OF LUNG RELATED PROBLEMS AMONG
SMOKERS.SCREEN INDIVIDUALS WITH NERVOUS,CIRCULATORY,BLOOD OR KIDNEY
CONDITIONS.
======================= First Aid Measures =======================
First Aid:REMOVE FROM EXPOSURE AND OBTAIN PROMPT MEDICAL ATTENTION.IF
NOT BREATHING,GIVE CPR.IF UNCONSCIOUS,GIVE OXYGEN;SKIN:WASH WITH
SOAP & WATER,IF IRR.PERSISTS,SEE DOCTOR;EYES:FLUSH WITH LARGE
AMOUNTS OF WA TER,IF IRR.PERSISTS,SEE DOCTOR.DO NOT WEAR CONTACT
LENSES;INGESTION:DRINK LARGE QUANTITIES OF WATER.INDUCE VOMIT,SEE
DOCTOR IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:NONCOMBUSTIBLE. USE EXTINGUISHING MEDIA APPROPRIATE
TO THE SURROUNDING FIRE.
Fire Fighting Procedures:TO EXTINGUISH A METAL POWDER FIRE USE DRY
SAND, OR CLASS D FIRE EXTINGUISHERS. USE WATER SPRAY TO COOL NEARBY
CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:IF IN SOLID FORM,SWEEP UP & PLACE IN
APPROPRIATE DISPOSAL CONTAINER.IF IN POWDER FORM,VACUUM WITH HIGH
EFF. PARTICULATE FILTRATION SYSTEM.MINIMIZE AIRBORNE GENERATION OF
POWDER & AVOID WATER CONTAMINA TION & PLACE IN APPROPRIATE DISPOSAL
CONTAINER.
======================Handling and Storage ======================
Other Precautions:TRAIN WELDER TO KEEP HIS HEAD OUT OF THE
FUMES.MONITOR AIR TO ENSURE ACCEPTABLE EXPOSURES.AVOID ELECTRICAL
SHOCK BY MAINTAINING DRY WORK AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FUME RESPIRATOR OR AIR SUPPLIED RESPIRATOR IN
CONFINED SPACES OR WHERE VENTILATION DOES NOT KEEP EXPOSURE BELOW
TLV.
Ventilation:LOCAL EXHAUST TO MAINTAIN BELOW TLV.
Other Protective Equipment:SUBSTANTIAL DARK CLOTH,ARM
PROTECTOR,APRON,HAT,SHOULDER PROTECTION.
Work Hygienic Practices:WASH HANDS THOROUGHLY BEFORE
EATING,SMOKING,USING SANITARY FACILITIES.
Supplemental Safety and Health
NONE.
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:SOLID WIRE OR ROD, GREY TO SILVER IN COLOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MINERAL ACIDS AND STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:FUMES OF METALS AND METAL
OXIDES,CO,NO*2,O*3.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF FUMES,FLUX OR WELD GRINDING RESIDUE
FROM THE WORK AREA OR FROM FILTERS IAW ALL APPLICABLE FEDERAL,STATE
AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:8386, PROTURF STARTER FERTILIZER 16-24-12
CAGE:FO079
CAGE:FO079
CAGE:6K952
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM CHLORIDE
CAS:7447-40-7
RTECS #:TS8050000
Ingred Name:SULFUR
CAS:7704-34-9
RTECS #:WS4250000
Ingred Name:UREA
CAS:57-13-6
RTECS #:YR6250000
Ingred Name:AMMONIUM DIHYDROGEN PHOSPHATE; (AMMONIATED PHOSPHATE ALT
CAS#7783-28-0)
CAS:7722-76-1
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC: MAY CAUSE EYE
IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:POSSIBLE NAUSEA, VOMITING & DIARRHEA. POSSIBLE
SKIN OR EYE IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:INDUCE VOMITING OR GASTRIC LAVAGE IF LARGE AMOUNTS
INGESTED. TREAT SYMPTOMATIC & SUPPORTIVE. SKIN:WASH EXPOSED AREAS.
EYES:FLUSH W/WATER FOR AT LEAST 15 MINS. IF IRRITATION PERSISTS,
SEE MD. IN HAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
O*2/ARTF RESP) .
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:SULFUR DUST CAN FORM EXPLOSIVE MIXTURES
W/AIR. IF PRODUCT IS CONSUMED IN A FIRE, TOXIC SULFUR DIOXIDE WILL
FORM.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP SPILLS. USE GOOD HOUSEKEEPING
PRACTICES. AVOID CONTACT W/SKIN, EYES OR CLOTHING. WASH AFTER
HANDLING.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:SEE LABEL. AVOID BAG BREAKAGE. KEEP
AWAY FROM FEED OR FOODSTUFFS. AVOID CONTACT W/SKIN, EYES OR
CLOTHING. KEEP OUT OF LAKES, STREAMS OR PONDS.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NOT APPLICABLE.
Other Protective Equipment:NOT APPLICABLE.
Work Hygienic Practices:WASH AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Appearance and Odor:GRANULAR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NOT APPLICABLE.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:UREA CAN GENERATE AMMONIA IN A FIRE.
==================== Disposal Considerations ====================
Waste Disposal Methods:REMOVE TO APPROVED LANDFILL. DISPOSAL MUST BE IN
ACCORDANCE W/FEDERAL, STATE & LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BOSTIK TL-52
CAGE:EO519
CAGE:98502
CAGE:EO519
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 20.0%
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 20.0%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 20.0%
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:METHYL ISOBUTYL KETONE (SARA III)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 10.0%
OSHA PEL:100 PPM/75 STEL
ACGIH TLV:50 PPM/75 STEL; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CYCLOHEXANONE (SARA III)
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: 15.0%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:NOSE & THROAT IRRITANT IF INHALED; ALSO NAUSEA
& VOMITING. CONTACT WITH SKIN & EYES MAY IRRITATE.
======================= First Aid Measures =======================
First Aid:SKIN: WASH WITH SOAP & WATER. EYE: FLUSH WITH WATER, CONSULT
PHYSICIAN. INHALATION: REMOVE TO FRESH AIR. CONSULT PHYSICIAN.
INGESTION: INDUCE VOMITING. CONSULT PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:23F (TCC)
Lower Limits:1.0
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL FOR SMALL FIRES.
Fire Fighting Procedures:USE AIR-SUPPLIED RESCUE EQUIPMENT IN ENCLOSED
SPACES.
Unusual Fire/Explosion Hazard:DO NOT APPLY TO HEATED SURFACES OR IN
AREAS WHERE ELECTRIC SPARKS MAY BE PRESENT.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB MATERIAL WITH SAWDUST OR OIL-ABSORBING
COMPOUND. WASH AREA WITH DETERGENT & WATER. USE ADEQUATE
VENTILATION TO CLEAR FUMES FROM AREA. AVOID SPARKS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE UNDER 100F. KEEP AWAY FROM HEAT,
SPARKS AND OPEN FLAME. KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:DO NOT STORE OR MIX WITH STRONG OXIDANTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE EITHER OBA OR SUITABLE CHEMICAL CARTRIDGE &
DUST FILTER RESP.
Ventilation:TO KEEP VAPORS BELOW TLV.
Other Protective Equipment:COVERALLS, APRON, NON-SPARKING SHOES, ETC.
Supplemental Safety and Health
XYLENE-ZE2100000 10%,S,100 PPM. BUTYL ALCOHOL-EO1400000 5%,C,S,50 PPM.
USE ALCOHOL-TYPE FOAM FOR LARGE FIRES. VAPOR DENSITY HEAVIER THAN
AIR.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:170-325F
Evaporation Rate & Reference:SLOWER THAN ETHER.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS
Stability Condition to Avoid:STORAGE AT HIGH TEMPERATURES.
Hazardous Decomposition Products:CARBON MONOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE WITH CARE. LANDFILL PREFERRED.
DISPOSE IN ACCORDANCE WITH LOCAL, STATE, & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: ATL AIR TOOL LUBRICANT, ATL004
Cage: 24869
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 24869
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50(ORAL):>5 G/KG
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: HLTH STUDIES HAVE SHOWN THAT MANY PETROL HYDROCARBS &
SYNTHETIC LUBRICANTS POSE POTNTL HUMAN HLTH RISKS WHICH VARY FROM PERSON TO
PERSON. AS PREC, EXPOS TO LIQS, VAPS, MISTS/FUMES SHOULD BE MIN. PRLNG D/RPTD
SKIN CONT TENDS TO REMOVE OILS POSS LEADING TO IRRIT & DERM; HOWEVER,
BASED ON HUMAN EXPER & (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZS:AVAIL TOX DATA, THIS PROD IS
JUDGED TO BE NEITHER "CORR" NOR AN "IRRIT" BY OSHA CRITERIA. PROD CONT EYE
MAY CAUSE IRRIT. PROD HAS LOW ORDER OF ORAL & DERM TOX. POSS ASPIR HAZ.
INDUCED VOMIT MAY CAUSE ASPIR OF PROD INTO LUNGS.
Medical Cond Aggravated By Exposure: UNKNOWN.
First Aid: EYE:FLUSH W/CLEAR WATER FOR @ LST 15 MIN/UNTIL IRRIT SUBSIDES. IF
IRRIT PERSISTS, CALL MD. SKIN:REMOVE CONTAM CLTHG & WASH SKIN THORO
W/SOAP & WATER. INHAL:VAP PRESS IS VERY LOW. VAP INHAL UNDER AMBIE NT
CNDTNS IS NORMALLY NOT PROBLEM. IF OVERCOME BY VAP FROM HOT PROD, IMMED
REMOVE FROM EXPOS & CALL MD. IF BRTHG IS IRREG/HAS STOPPED, START
RESUSCITATION, ADMIN OXYG IF AVAIL. IF OVEREXP TO
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS (FP N).
Handling And Storage Precautions: EMPTY CONTAINERS RETAIN RESIDUE (LIQUID OR
VAPOR AND CAN BE DANGEROUS.
Other Precautions: DO NOT PRESS, WELD, CUT, BRAZE, SOLDER, DRILL, GRIND/EXPOSE
SUCH CNTNRS TO HEAT, FLAME, SPKS/OTHER IGNIT SOURCES, THEY MAY EXPLODE &
CAUSE INJURY/DEATH. DO NOT ATTEMPT TO CLEAN SINCE RESIDUE IS DFCLT TO
REMOVE. "EMPTY" DRUMS SHOULD
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: COC
Flash Point Text: 354F,179C
Lower Limits: 1%
Upper Limits: 6%
Extinguishing Media: FOAM, WATER SPRAY (FOG), DRY CHEM, CARBON DIOXIDE &
VAPORIZING LIQ TYPE EXTING AGENTS MAY ALL BE SUITABLE FOR (SUP DAT)
Fire Fighting Procedures: WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP (FP N).
FOLLOWING PROCEDURES FOR THIS TYPE OF PROD ARE BASED ON RECS IN NATL FIRE
PROT ASSOC'S "FIRE PROT GUIDE
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N).
Ventilation: NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment: ANSI APPROVED EMERGENCY EYE WASH AND DELUGE SHOWER
(FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: USERS OF "L" VERSION CONSULT "LR" VERSION FOR
ADDNL INFO (FP N). % VOLAT:NEGLIGIBLE. EXTING MEDIA:EXTING FIRES INVOLVING
THIS TYPE PROD, DEPENDING ON SIZE/POTNTL SIZE OF FIRE & CIRCUMSTANCE
RELATED TO SITUATION. PLAN FIRE PROT & RESPONSE STRATEGY THRU
CONSULTATION W/LOC FIRE PROT AUTHS/APPROP SPECIALISTS.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: WIDE RANGE
Vapor Pres: <0.1 @ 38C
Vapor Density: >8
Spec Gravity: <1 (H*2O=1)
Solubility in Water: NEGLIGIBLE
Appearance and Odor: AMBER LIQUID; PETROLEUM ODOR.
Percent Volatiles by Volume: SUPDAT
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: AVOID CONT W/STRONG OXIDANTS SUCH AS LIQ CHLORINE, CONC
OXYG, SODIUM HYPOCHLORITE OR CALCIUM HYPOCHLORITE.
Hazardous Decomposition Products: FUMES, SMOKE, CARBON MONOXIDE, OXIDES OF
SULFUR, AND OTHER DECOMPOSITION PRODUCTS, IN CASE OF INCOMPLETE COMBUSTION.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: ATL AIR TOOL LUBRICANT, ATL004
Cage: 24869
Company Name: DIXON VALVE & COUPLING CO
Street: 800 HIGH ST
Zipcode: 21620-1136
Label Required IND: Y
Date Of Label Review: 12/10/1996
Status Code: C
Label Date: 12/10/1996
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE:PRODUCT CONTACTING THE EYE MAY CAUSE
IRRITATION. PRODUCT HAS A LOW ORDER OF ORAL AND DERMAL TOXICITY. POSSIBLE
ASPIRATION HAZARD. INDUCED VOMITING MAY CAUSE ASPIRATION OF PRODUCT IN TO THE
LUNGS. CHRONIC:PROLONGED OR REPEATED SKIN CONTACT TENDS TO REMOVE SKIN OILS
POSSIBLY LEADING TO IRRITATION AND DERMATITIS.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1,3-DIETHYL-2-THIOUREA, 98%, D10090-0
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:UREA, 1,3-DIETHYL-2-THIO-; (1,3-DIETHYL-2-THIOUREA)
CAS:105-55-5
RTECS #:YS9800000
Fraction by Wt: 98%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT) 316 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:HARMFUL IF SWALLOWED, INHALED OR
ABSORBED THROUGH SKIN. MAY CAUSE IRRITATION. CHRONIC:CARCINOGEN. TO
THE BEST OF MFR'S KNOWLEGDE, THE CHEMICAL, PHYSICAL & TOXICOLOGICAL
PROPERTIES HAVE NOT BEEN THOROUGHLY INVESTIGATED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:IMMEDIATELY FLUSH W/COPIOUS AMOUNTS OF WATER FOR AT
LEAST 15 MINUTES. SKIN:IMMEDIATELY FLUSH W/COPIOUS AMOUNTS OF WATER
FOR AT LEAST 15 MINUTES WHILE REMOVING CONTAMINATED CLTHG & SHOES.
DISCARD CONTAMINATED CLTHG & SHOES. INHAL:REMOVE TO FRESH AIR. IF
NOT BREATHING GIVE ARTF RESP. IF BREATHING IS DIFFICULT, GIVE
OXYGEN. INGEST:WASH OUT MOUTH W/WATER PROVIDED PERSON IS CONSCIOUS.
CALL MD.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL POWDER OR
APPROPRIATE FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR NIOSH/MSHA APPROVED SCBA,
DISCARD THEM AFTER USE. SWEEP UP, PLACE IN A BAG & HOLD FOR WASTE
DISPOSAL. VENTILATE AREA & WASH SPILL SITE AFTER MATL PICKUP
ISCOMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT BREATHE DUST. AVOID ALL
CONTACT. CARCINOGEN. TOXIC. HARMFUL SOLID. KEEP TIGHTLY CLOSED.
STORE IN A COOL, DRY PLACE.
Other Precautions:MAY CAUSE CANCER. HARMFUL BY INHALATION, IN CONTACT
W/SKIN & IF SWALLOWED. IF YOU FEEL UNWELL, SEEK MEDICAL ADVICE
(SHOW LABEL WHERE POSSIBLE).
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:WEAR APPROPRIATE PROTECTIVE CLOTHING. SAFETY
SHOWER & EYE BATH.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
EYE PROT:& FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
HCC:T6
Melt/Freeze Pt:M.P/F.P Text:>169F,>76C
Appearance and Odor:OFF-WHITE FLAKES.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF: CARBON MONOXIDE,
CARBON DIOXIDE, NITROGEN OXIDES, SULFUR OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE OR MIX MATERIAL W/COMBUSTIBLE SOLVENT &
BURN IN A CHEMICAL INCINERATOR EQUIPPED W/AFTERBURNER & SCRUBBER.
OBSERVE ALL FEDERAL, STATE & LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ESTERON (R) BRAND 99 CONCENTRATE
CAGE:9Z672
CAGE:9Z672
============= Composition/Information on Ingredients =============
Ingred Name:2,4-DICHLOROPHENOXYACETIC ACID, 2-ETHYLHEXYL ESTER (SARA
III) (NO EXPOSURE LIMITS HAVE BEEN ESTABLISHED FOR THE ACTIVE
CAS:1928-73-3
RTECS #:AG7700000
Fraction by Wt: 65.9%
Other REC Limits:NONE SPECIFIED
Ingred Name:# INGREDIENT IN THIS FORMULATION. HOWEVER, FOR THE FREE
ACID 2,4-D, THE FOLLOWING APPLIES
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
OSHA PEL:10 MG/CUBIC M TWA
ACGIH TLV:10 MG/CUBIC M TWA
Ingred Name:KEROSENE
CAS:8008-20-6
RTECS #:OA5500000
Other REC Limits:NONE SPECIFIED
Ingred Name:PROPRIETARY EMULSIFIERS
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 RAT: 1792 MG/KG, DERMAL LD50**
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:UNKNOWN IARC:YES
Health Hazards Acute and Chronic:INGEST: HARMFUL. NAUSEA, VOMIT, ABDOM
PAIN, DIARRHEA, PINPOINT PUPILS, BLURRED VISION, PROFUSE SWEATING,
SALIVATION, TREMOR, MUSCLE TWITCHING, & TEMP PARALYSIS. IN SEVERE
POISONING RESPIRATORY DEPRESS & CONVULSIONS MAY OCCUR. PRODUCT
CONTAINS PETROLEUM DISTILLATES. ASPIRATION MAY OCCUR AFTER
SWALLOWING, MAY RESULT ***
Explanation of Carcinogenicity:IARC CLASSIFIES CHLOROPHENOXY HERBICIDES
AS 2B CARCINOGEN, LIMITED EVIDENCE IN HUMANS. SCIENCE ADVISORY OF
EPA: CLASS D.
Effects of Overexposure:** RABBITS: >2,000 MG/KG.
*** IN CHEMICAL PNEUMONITIS. SKIN ABSORPTION: HARMFUL. SKIN:
IRRITATION. EYE: MODERATE IRRITATION. REPEATED OVEREXPOSURE: LIVER,
KIDNEY, GASTROINTESTIN AL & MUSCULAR EFFECTS. RARE: PERIPHERALNERVE
DAMAGE. REPEATED EXPOSURE: DRY & DEFAT SKIN, IRRITATION,
DERMATITIS, BURN.
Medical Cond Aggravated by Exposure:SKIN IRRITATION MAY BE AGGRAVATED
IN PERSON W/PREEXISTING SKIN LESIONS. BREATHING OF VAPOR/SPRAY
MISTS MAY AGGRAVATE ACUTE OR CHRONIC ASTHMA & CHRONIC PULMONARY
DISEASE.
======================= First Aid Measures =======================
First Aid:REMOVE FROM IMMED SOURCE OF EXPOSURE. ASSURE THAT INDIVIDUAL
IS BREATHING. INGEST: IF CONSCIOUS & ALERT, GIVE 2-3 GLASSES WATER
TO DRINK. DONT INDUCE VOMIT. GET MED AID. PREVENT ASPIRATION OF
SWALLOWE D PRODUCT, LAY PATIENT ON SIDE W/HEAD LOWER THAN WAIST.
SKIN: IMMED WASH W/SOAP & WATER, REMOVING CONTAM CLOTH & SHOES.
INHAL: REMOVE TO FRESH AIR. IF NOT BREATH, GIVE CPR/ARTIF RESP IF
BREATH***
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:150F,66C
Lower Limits:0.9
Upper Limits:6.0
Extinguishing Media:USE CARBON DIOXIDE, DRY CHEMICAL FOR SMALL FIRES.
USE WATER SPRAY OR FOAM (ALCOHOL/POLYMER/ORDINARY) FOR LARGE FIRES.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND USE
SELF-CONTAINED BREATHING APPARATUS. DIKE AREA TO PREVENT RUNOFF AND
CONTAMINATION OF WATER SOURCES.
Unusual Fire/Explosion Hazard:THERMAL DECOMP PRODUCTS MAY BE HAZARDOUS.
THESE MAY INCLUDE HYDROGEN CHLORIDE, THE OXIDES OF CARBON AND
HYDROCARBONS.
================== Accidental Release Measures ==================
Spill Release Procedures:LRG: DIKE W/ABSORB. RECOVER FREE LIQ. RECOVER
REMAIN SPILL AS APPROP. COLLECT & CONTAIN CONTAM ABSORB. SMALL:
ABSORB W/SAND/VERMIC. PLACE CONTAM MAT'L IN CNTNR. IF SPILLED ON
GRND, REMOVE TO DEPTH OF 1-2 INCHES, PLACE IN CNTNR. DONT FLUSH TO
SEWER #
Neutralizing Agent:N/K***DIFFICULT, GIVE OXYGEN. GET MED AID. EYE:
FLUSH W/WTR 15MIN GET MED AID.
======================Handling and Storage ======================
Handling and Storage Precautions:COMBUST LIQ. ELIMINATE IGNIT
SOURCES/HEAT/SPARKS UNTIL AREA FREE OF FIRE/EXPLOS HZD. DONT
INGEST. AVOID INHALATION, GETTING IN EYES, ON SKIN/CLOTHING.
Other Precautions:DONT STORE NEAR HEAT, SPARKS, OPEN FLAME, OR OTHER
IGNITION SOURCES. DONT STORE NEAR FOOD, FEEDSTUFFS, FERTILIZER OR
SEED. DONT CONTAMINATE WATER, FOOD OR FEED BY STORAGE OR DISPOSAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA RESPIRATOR FOR PESTICIDE MIST.
USE POSITIVE PRESSURE SELF-CONTAINED BREATHING APPARATUS FOR
EMERGENCY CONDITIONS.
Ventilation:MECHANICAL (GENERAL) VENTILATION.
Other Protective Equipment:PROTECTIVE CLOTHING, SAFETY SHOWER
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NOTE TO DR:NO SPECIFIC ANTIDOTE.TREAT SYMPTOMATICALLY.CONSIDER WHETHER
OVEREXPOS TO OTHER MAT'LS OCCURRED.PROD CONTAINS PETROLEUM
DISTILLATES.IF LRG AMTS(>1 ML/KG)INGEST,EVACUATE STOMACH.AFTER
REMOVAL WASH STOMACH BY INSTILLING 30-50 G ACTIVATED CHARCOAL IN
3-4 OZ WATER-REMOVE.AVOID OILY LAXATIVES.MORE INFO ON FILE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>302F,>150C
Vapor Pres:0.4 *
Vapor Density:4.7 *
Spec Gravity: 1.03 @ 20/20 C
Evaporation Rate & Reference:N/K * (KEROSENE)
Solubility in Water:EMULSIFIABLE
Appearance and Odor:AMBER LIQUID; HYDROCARBON ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, BASES, STRONG OXIDIZERS.
Stability Condition to Avoid:DO NOT STORE NEAR HEAT, SPARKS, OPEN FLAME
OR OTHER IGNITION SOURCES.
Hazardous Decomposition Products:MAY INCLUDE HYDROGEN CHLORIDE, THE
OXIDES OF CARBON, AND HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORD W/LOCAL, STATE & FED REGS.
RCRA HAZARDOU WASTE # D001, IGNITABLE. SPILL SUBJECT TO CERLCA
REPORT: RQ = 100 LBS.# WATERWAYS. WEAR
PROTECT CLOTH & EQUIP DURING C LEANUP. USE NON SPARK TOOLS.
DECONTAM EQUIP/TOOLS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:122 7487 KODAK STABILIZER/REPLENISHER, PROCESS E-6AR, MX1600
Kit Part:Y
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:FORMALDEHYDE (SARA 302/313) (CERCLA)
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: 15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE 1910.1048
ACGIH TLV:C 0.3 PPM, A2; 9596
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA 313) (CERCLA)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S, 200 PPM
ACGIH TLV:S,200PPM/250STEL; 96
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:NONIONIC SURFACTANT
CAS:24938-91-8
RTECS #:YD4571000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 75-80%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INHALATION: IT PRODUCES MILD SENSORY
IRRITATION OF THE EYES, NOSE & THROAT. AT HIGHER CONCENTRATIONS
CAUSING SEVERE BURNING SENSATION OF THE NOSE & THROAT WITH
COUGHING. SKIN: CAUSES IRRITATION. INGES TION: MAY BE FATAL OR
CAUSE BLINDNESS IF SWALLOWED.
Explanation of Carcinogenicity:CONTAINS F [50-00-0] WHICH IS
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:INHALATION-MAY CAUSE CHEST CONSTRICTION,
HEADACHE, BRONCHOPNEUMONIA, DYSPHAGIA, EDEMA & SPASMS OF THE LARYNX
& DYSPNEA. EYES-EYE IRRITATION & TEARING. INGESTION-MAY CAUSE BURNS
OF THE ESOPHAGUS & STOM ACH. RETINAL & KIDNEY DAMAGE,
IMMEDIATESEVERE ABDOMINAL PAIN, VOMITING, NAUSEA, DIARRHEA,
DIZZINESS, COMA & DEATH.
Medical Cond Aggravated by Exposure:EXPOSURE TO FORMALDEHYDE MAY CAUSE
RESPIRATORY SENSITIZATION IN SOME INDIVIDUALS OR AGGRAVATE
PRE-EXISTING ASTHMATIC CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHALATION-MOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN. GET
MEDICAL ATTENTION. EYES-IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR
AT LEAST 15 MIN. GET MEDICAL ATTENTION. SKIN-IMMEDIATELY FLUSH
WITH PLENTY OF WATER FOR AT LEAST 15 MIN WHILE REMOVING CLOTHES.
GET MEDCIAL ATTENTION. INGESTED-DO NOT INDUCE VOMITING. GIVE VICTIM
A GLASS OF WATER
===================== Fire Fighting Measures =====================
Flash Point:100F-199F
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL
FOAM. USE WATER SPRAY TO KEEP FIRE EXPOSED CONTAINER COOL.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:CLASSIFIED AS COMBUSTIBLE. MATERIAL
CONTAINS A COMBUSTIBLE SOLVENT THAT MAY ACCUMULATE IN THE CONTAINER
HEADSPACE.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. ABSORB SPILL
WITH VERMICULITE OR OTHER INERT MATERIAL, THEN PLACE IN A CONTAINER
FOR CHEMICAL WASTE. CLEAN SURFACE THOROUGHLY TO REMOVE RESIDUAL
CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY KEEP AWAY FROM
INCOMPATIBLE SUBSTANCES.
Other Precautions:DO NOT BREATHE VAPOR. DO NOT GET IN EYES, ON SKIN, ON
CLOTHING. USE WITH ADEUATE VENTILATION. WASH THOROUGHLY AFTER
HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF FORMALDEHYDE IS EMITTED AT LEVELS REQUIRING
RESPIRATORY PROTECTION, THE FOLLOWING RESPIRATOR TYPE SHOULD BE
WORN: FULL FACEPIECE WITH CARTRIDGE OR CANISTERS SPECIFICALLY
APPROVED BY NIOSH FOR PROTE CTION AGAINST FORMALDEHYDE OR C-TYPE.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES/HR)
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:WEAR PROTECTIVE CLOTHING APPROPIATE FOR THE
RISK OF EXPOSURE. EYE BATH, SAFETY SHOWER, WASHING FACILITIES.
Work Hygienic Practices:IT IS GOOD INDUSTRIAL HYGIENE PRACTICE TO
MINIMIZE EYE CONTACT. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
KEEP OUT OF REACH OF CHILDREN.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>199F,>93C
Vapor Pres:18 MMHG
Vapor Density:0.6 AIR=1
Spec Gravity:1.03
pH:5.00
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID, COLORLESS, STRONG FORMALDEHYDE ODOR.
Percent Volatiles by Volume:99
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS, STRONG BASES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:FORMALDEHYDE. CARBON DIOXIDE, CARBON
MONOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE, OR LOCAL LAWS. CONTRACT WITH A LICENSED
CHEMICAL DISPOSL AGENCY. SINCE EMPTIED CONTAINER RETAIN PRODUCT
RESIDUE, FOLLOW LABEL WARNI NGS EVEN AFTER CONTAINER IS EMPTIED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:60231 XL MICROCEL LIGHT BODY FILLER
CAGE:GO640
CAGE:GO640
============= Composition/Information on Ingredients =============
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE *96-3*
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 32-42%
OSHA PEL:2 MG/CUM (RESP DUST)
ACGIH TLV:2 MG/CUM (RESP DUST)
Ingred Name:CALCIUM CARBONATE, DOMOLITE, LIMESTONE, WHITING *96-3*
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 1-10%
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:SODIUM BORATED SILICATE *96-3*
CAS:50815-87-7
Fraction by Wt: 1-5%
Ingred Name:AMORPHOUS SILICA GEL, SILICON DIOXIDE *96-3*
CAS:7631-86-9
Fraction by Wt: 1-5%
Ingred Name:STYRENE, STYRENE MONOMER (SUSPECTED ANIMAL/HUMAN
CARCINOGEN BY IARC GROUP 2B) *96-3*
CAS:100-42-5
RTECS #:WL3675000
Fraction by Wt: 15-20%
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: CAN CAUSE IRRITATION. SKIN:
IRRITATION, DERMATITIS, DEFATTING MAY BE READILY ABSORBED THROUGH
THE SKIN. INHALATION: NASAL & RESPIRATORY IRRITATION. ASPHYXIATION.
ASPIRATION OF MATERIAL INTO LUNG S MAY RESULT IN CHEMICAL
PNEUMONITIS, WHICH CAN BE FATAL. INGESTION: GI IRRITATION.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, REDNESS, TEARING, BLURRED VISION,
SWELLING, MINOR ITCHING, BURNING, DEFATTING, DIZZINESS, WEAKNESS,
FATIGUE, NAUSEA, HEADACHE, UNCONSCIOUSNESS, ASPHYXIATION, VOMITING,
DIARRHEA
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE TO WELL VENTILATED AREA.
MAKE COMFORTABLY WARM, BUT NOT HOT. USE OXYGEN/CPR AS REQUIRED.
SKIN: WASH PROMPTLY W/SOAP & EXCESS WATER. EYES: FLUSH PROMPTLY
W/EXCESS WATER FOR 15 MINS. INGESTION: DON'T INDUCE VOMITING. GIVE
VICTIM A GLASS OF WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:89F
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:FIGHT LIKE A FUEL OIL FIRE. COOL FIRE EXPOSED
CONTAINERS W/WATER SPRAY. WEAR OSHA/NIOSH APPROVED SELF CONTAINED
BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS EXPOSED TO HIGH
TEMPERATURES, SUCH AS FIRE CONDITIONS MAY RUPTURE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE ALL SOURCES OF
IGNITION. AVOID PROLONGED BREATHING OF VAPOR. CONTAIN LEAK W/INERT
ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE PRODUCT >100F. DON'T
FLAME/CUT/BRAZE/WELD/MELT EMPTY CONTAINERS. KEEP AWAY FROM HEAT,
OPEN FLAME & OTHER IGNITION SOURCES.
Other Precautions:AVOID CONTACT W/STRONG ACIDS/ALKALIES & OXIDIZERS.
AVOID CONTACT W/EYES & SKIN & BREATHING OF VAPORS. USE W/ADEQUATE
VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV LIMITS ARE EXCEEDED, USE NIOSH/MSHA
APPROVED RESPIRATOR TO REMOVE VAPORS. USE AN AIR SUPPLIED
RESPIRATOR IF NECESSARY.
Ventilation:ADEQUATE TO KEEP TLV/PEL BELOW RECOMMENDED LEVELS.
EXPLOSION PROOF VENTILATION MAY BE NECESSARY.
Other Protective Equipment:SIDE SHIELDS, PROTECTIVE CLOTHNG AS REQUIRED
TO PREVENT SKIN CONTACT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Density:>1
Spec Gravity:1.15
VOC Pounds/Gallon:215
Evaporation Rate & Reference:SLOWER THAN ETHYL ETHER
Solubility in Water:NONE
Appearance and Odor:OFF-WHITE SMOOTH PASTE
Percent Volatiles by Volume:15-20
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, ALKALIES, OXIDIZERS
Stability Condition to Avoid:HIGH TEMPERATURES, HEAT, OPEN FLAMES,
SPARKS, ELECTRICAL & STATIC DISCHARGE
Hazardous Decomposition Products:CO2, CO, CARBON
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:358 EL MORRO VINYL FLAT
CAGE:FO135
CAGE:91950
CAGE:FO135
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS FOR INGREDIENTS
Fraction by Wt: 100%
===================== Hazards Identification =====================
Effects of Overexposure:EYE: PRIMARY IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH CLEAN WATER. IF IRRITATION PERSISTS CALL
PHYSICIAN.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:NON-COMBUSTIBLE.
Unusual Fire/Explosion Hazard:NON-COMBUSTIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH WITH WATER. ABSORB WITH SAWDUST OR RAGS.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T THROW OR DROP CONTAINERS. DON'T
TAKE INTERNALLY. CLOSE CONTAINER AFTER EACH USE. AVOID ES
CONT/PROLONGED SKIN OR BREATHING OF SPRAY MIST.
Other Precautions:KEEP AWAY FROM CHILDREN.
============= Exposure Controls/Personal Protection =============
Supplemental Safety and Health
MSDS DATE: 04/86. THESE PRODUCTS ARE NON-COMBUSTIBLE WATER EMULSION
PAINTS FORMULATED W/O LEAD OR MERCURY. THEY AREN'T HAZDOUS
SUBSTANCES UNDER CURRENT DEPARTMENT OF LABOR DEFINITIONS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:CONVENTIONAL METHODS IN COMPLIANCE WITH LOCAL,
STATE, AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:COPPERTONE SPORT LOTION SPF-30, 03173-30
CAGE:4N221
CAGE:4N221
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES/SKIN:NON-IRRITATING.
INHALATION:NOT APPLICABLE. INGESTION:PRACTICALLY NON-TOXIC.
CHRONIC:NONE KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD . NONE
REQUIRED. EYES:FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15 M
INUTES. INGESTION:DRINK LARGE AMOUNTS OF MILK OR WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, CO*2, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB LIQUID AND DISPOSE OF PROPERLY. WASH
ANY REMAINING RESIDUE WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID HIGH TEMPERATURES TO PREVENT
PLASTIC CONTAINER FROM MELTING.
Other Precautions:CONTAINER DISPOSAL:DO NOT REUSE EMPTY CONTAINER. WRAP
CONTAINER AND PUT IN TRASH COLLECTION. AVOID CONTACT WITH EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NONE FOR CONSUMER PACKAGE.
Ventilation:NOT APPLICABLE.
Other Protective Equipment:IN BULK:EYE, SKIN AND RESPIRATORY PROTECTION
AS NEEDED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:<1
Solubility in Water:NOT DETERMINED
Appearance and Odor:VISCOUS CREAM COLOR LIQUID WITH CHARACTERISTIC
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, STRONG OXIDIZERS.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE. (ONLY
UNDER INCOMPLETE THERMAL DECOMPOSITION)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NATURAL GRAPHITE
Preparer's Name:AVT
CAGE:69933
CAGE:69933
============= Composition/Information on Ingredients =============
Ingred Name:GRAPHITE, NATURAL
CAS:7782-42-5
RTECS #:MD9659600
= Wt:100.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MPPCF RDUST
ACGIH TLV:2 MG/M3 RDUST; 9293
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Minumum % Wt:0.
Maxumum % Wt:4.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV FOR QUARTZ,RESPIRABLE DUST 0.1 MG/M3
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:CASES OF PULMONARY FIBROSIS, EMPHYSEMA
AND CORPULMONATE MAY RESULT FROM PROLONGED INHALATION OF DUST
(CHRONIC). MINOR SKIN AND/OR EYE IRRITATION MAY OCCUR.
Explanation of Carcinogenicity:IARC CONCLUDED THAT THER IS SUFFICIENT
EVIDENCE THAT INHALED CRYSTALLINE SILICA CAUSES CANCER IN HUMANS.
IARC CLASSIFICATION GROUP 1.
Effects of Overexposure:INHALATION-NOSE AND/OR THROAT IRRITATION,
SHORTNESS OF BREATH. SKIN/EYES-REDNESS OF SKIN, IRRITATION OF EYES.
Medical Cond Aggravated by Exposure:EMPHYSEMA, ASTHMA OR OTHER
RESPIRATORY PROBLEMS.
======================= First Aid Measures =======================
First Aid:INHALATION-REMOVE FROM DUST AREA. SEEK MEDICAL ATTENTION IF
SYMPTOMS PERSISTS. SKIN-WASH WITH SOAP & WATER. EYE-RINSE EYES WITH
STERILE EYE WASH. SEEK MEDICAL ATTENTION IF ANY IRRITATION
PERSISTS.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER
Fire Fighting Procedures:SPRAY WITH WATER
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP OR VACUUM.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE AND TRANSFER IN A MANNER WHICH
AVOIDS EXCESSIVE DUSTING. STORE AWAY FROM OXIDIZING AGENTS.
Other Precautions:GRAPHITE IS A CONDUCTOR OF ELECTRICITY. EXERCISE
CAUTION WHEN HANDLING GRAPHITE IN AREAS WHERE CONTACT WITH
ELECTRICAL CIRCUITRY IS POSSIBLE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR FOR NUISANCE DUST.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:KEEP WORK AREA CLEAN, USE ADEQUATE DUST
COLLECTION/VENTILATION TO MAINTAIN LEVELS OF DUST BELOW ACGIH-TLV.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:2.20-2.35
Viscosity:NOT RELEVANT
Evaporation Rate & Reference:N/A(BUTYL ACETATE=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:GREY TO BLACK NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENT.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN APPROVED MANNER BASED ON
FEDERAL/LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FLAT WHITE SPRAY ENAMEL, 55-317
CAGE:47695
CAGE:47695
============= Composition/Information on Ingredients =============
Ingred Name:VENT:THE LEL BELOW THE STATED LIMIT, & TO REMOVE DECOMP
PROD DURING WELDING/FLAME CUTTING ON SURF COATED W/THIS PROD.
RTECS #:9999999ZZ
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 5-10%
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 5-10%
OSHA PEL:15MG/M3 TDUST; 5RESP
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 10-15%
OSHA PEL:200 PPM; 300 STEL
ACGIH TLV:200 PPM; 300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETONE (SARA III)
CAS:67-64-1
RTECS #:AL3150000
OSHA PEL:750PPM; 1000 STEL
ACGIH TLV:750PPM; 1000 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENES (SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 20-25%
OSHA PEL:100 PPM; 150 STEL
ACGIH TLV:100 PPM; 150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 10-15%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT
Ingred Name:PROPANE, 2-METHYL-; (ISOBUTANE)
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 10-15%
Ingred Name:FILM FORMERS, RESINS, AND ADDITIVES
Fraction by Wt: 2-5%
Ingred Name:SUPDAT:SINCE OVEREXP NOT EXPECTED, THERE IS NO SIGNIFICANT
HAZ FOR MAN. EYE WATERING, HDCH, NAUS, DIZZ & LOSS (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:OF COORDINATION ARE INDICATIONS THAT SOLV LEVELS ARE
TOO HIGH. REDNESS,ITCHING SENSATION & VISUAL DISTURB (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:MAY INDICATE EXCESSIVE EYE CNTCT. DRYNESS, ITCHING,
CRACKING, BURNING, REDNESS & SWELLING ARE CONDTNS (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:ASSOC W/EXCESSIVE SKIN CONTACT.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:THE USE OF THIS PROD, CNTCT POIS CTL CTR,
EMER ROOM OR MD IMMED. HAVE MSDS INFORMATION AVAIL.
RTECS #:9999999ZZ
Ingred Name:RESP:DETERMINE TYPE OF AIRBORNE CONTAM AGAINST WHICH RESP
IS EFTIVE & HOW IT IS TO BE PROPERLY FITTED.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INGEST:HARMFUL/FATAL IF
SWALLOWED. EYES:CAUSES IRRIT. SKIN:MAY CAUSE MOD IRRIT. INHAL:VAP &
SPRAY MIST MAY BE HARMFUL. VAP IRRIT EYES, NOSE & THROAT. RPTD
EXPOS TO HIGH VAP CONC MAY CAUSE IRRIT OF RESP SYS & PERM BRAIN &
NERVOUS SYS DMG. INTENTIONAL MISUSE BY DELIB CONC & INHAL CONTENTS
CAN BE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:HARMFUL/FATAL. CHRONIC:AVOID LONG TERM
& RPTD CNTCT. THIS PROD CONTAINS TITANIUM DIOXIDE. ANIMALS INHAL
MASSIVE QTYS OF TITANIUM DIOXIDE DUST IN LONG-TERM STUDY DEVELOPED
LUNG TUMORS. STUDIES W/HUMANS INVOLVED IN MFG OF THIS PIGMENT
INDICATE NO INCR RISK OF CANCER FROM EXPOS. POTNTL FOR INHAL OF
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:DO NOT INDUCE VOMIT. EYES:FLUSH IMMED W/PLENTY OF
WATER FOR AT LEAST 15 MIN. SKIN:FLUSH IMMED W/PLENTY OF WATER,
FOLLOWED BY WATERLESS HAND CLEANER & SOAP & WATER IF MATL APPEARS
TO ADHERE TO S KIN. INHAL:IF AFFECTED BY VAP/SPRAY MIST, REMOVE TO
FRESH AIR. APPLY ARTF RESP & OTHER SUPPORTIVE MEASURES AS REQD.
OTHER:IF INGEST/ANY TYPE OF OVEREXP/SYMP OF OVEREXP OCCUR
DURING/FOLLOWING (ING 13)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:15.0F,-9.4C
Lower Limits:2.3%
Extinguishing Media:USE NFPA CLASS B EXTING(CO2, DRY CHEM/UNIVERSAL AQ
FILM FORMING FOAM) DESIGNED TO EXTING NFPA CLASS IA FLAMM LIQ
FIRES.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER SPRAY MAY BE INEFTIVE. WATER SPRAY MAY BE USED TO COOL CLSD
CONTRS TO PVNT PRESS BUILD-UP & (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPARKS & OPEN FLAMES. CLSD CONTRS MAY EXPLODE
WHEN EXPOS TO EXTREME HEAT. DO NOT APPLY ON HOT (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:PROVIDE MAX VENT. ONLY PERS EQUIPPED W/ PROPER
RESP & SKIN & EYE PROT SHLD BE PERMITTED IN AREA. REMOVE ALL
SOURCES OF IGNIT. TAKE UP SPILLED MATL W/SAWDUST, VERMICULITE/OTHER
ABSORB MATL & PLACE INTO CONTRS FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. STORE LG QTYS
IN BUILDINGS DESIGNED & PROTECTED FOR STOR OF NFPA CLASS IA FLAMM
LIQUIDS.
Other Precautions:IF THIS MATL IS PART OF MULTIPLE COMPONENT COATING
SYS, READ MSDS(S) FOR OTHER COMPONENT(S) BEFORE BLENDING AS RSLTG
MIX MAY HAVE HAZ OF ALL OF ITS PARTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:OVEREXP TO VAP MAY BE PVNT BY ENSURING VENT
CONTROLS, VAP EXHST/FRESH AIR ENTRY. NIOSH/MSHA APPRVD (TC-23C-)
AIR PURIFYING/AIR SUPPLIED (TC-19C-) RESP MAY ALSO REDUCE EXPOS.
READ RESP MFR INSTRUCTIONS& LITERATURE CAREFULLY TO (ING 14)
Ventilation:PROVIDE GEN DILUTION/LOC EXHAUST VENT IN VOL & PATTERN TO
KEEP CONC OF INGRED BELOW LOWEST SUGGESTED EXPOS LIM, (ING 15)
Other Protective Equipment:WEAR PROTECT CLTHNG, INCL IMPERM APRON.
EMERG EYEWSH MTG ANSI DSGN STNDS . EYE PROT: FULL LGTH FCSHLD .
Work Hygienic Practices:CLEAN OR DISCARD CONTAMD CLOTHING & SHOES.
Supplemental Safety and Health
FIRE FIGHT PROC:POSS AUTOIGNIT/EXPLOSION WHEN EXPOSED TO EXTREME HEAT.
IF WATER USED, FOG NOZZLES PREF. EXPLO HAZ: SURF. TOXIC GASES MAY
FORM WHEN PROD CONTACTED BY FLAM/HOT SURF. AEROSOL- CONTRS HOLD
EXTREMELY FLAMM GAS & FLAMM LIQ UNDER PRESS. EFTS OF OVEREXP:
TITANIUM DIOXIDE DUSTS FROM COATINGS IS VERY LIMITED.(ING
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:>-69F,>-56C
Vapor Pres:57.4
Vapor Density:HVR/AIR
Spec Gravity:0.85
Evaporation Rate & Reference:389 (BUOAC=100)
Solubility in Water:20.6%
Appearance and Odor:PRESSURIZED CAN CONTAINING PAINT & PROPELLANTS
W/ODOR CHARACT OF SOLV IN INGS.
Percent Volatiles by Volume:91.10
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/STRONG ALKALIES, STRONG MINERAL ACIDS, OR STRONG
OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY PRDCE HAZ DECOMP PROD WHEN HEATED.
WELDING, BRAZING/FLAME-CUTTING ON SURF COATED W/PROD MAY PRDCE
FUMES INCL: CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MATL MUST BE DISPOSED OF I/A/W FED, STATE,
PROVINCIAL & LOCAL ENVIR CONTROL REGS. EMPTY CONTRS SHLD BE
RECYCLED OR DISPOSED OF THROUGH AN APPRVD WASTE MANAGEMENT
FACILITY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CUSTOM PLASMA STANDARD, PLSI9-2Y
Preparer's Name:VANAJA SIVAKUMAR
CAGE:IO044
CAGE:07977
CAGE:IO044
============= Composition/Information on Ingredients =============
Ingred Name:SILICATE(2-), HEXAFLUORO-, DIAMMONIUM; ((NH*4)*2SIF*6). %
WT: 0.64-6.4
CAS:16919-19-0
RTECS #:VV7800000
Fraction by Wt: SEE ING
OSHA PEL:N/K
ACGIH TLV:10 MG/M3 (SI) (MFR)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 90-98%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS SOLUTION MAY BE HARMFUL IF
INHALED, INGESTED, OR CONTACTED W/SKIN/EYES. INHALATION OF AMMONIUM
HEXAFLUOROSILICATE CAN LEAD TO RESPIRATORY DISORDERS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MINUTES OCCAS LIFT LIDS.
SKIN: REMOVE CONTAMINATED CLOTHING, THEN FLUSH W/WATER FOR AT LEAST
15 MINUTES. WASH CLTHG THORO BEFORE REUSE. INHAL: MOVE TO FRESH
AIR. IF IRRIT CONTINUES, GET MED ATTN IMMED. INGEST: DO NOT INDUCE
VOMITING. GET IMMED MED HELP. IF PATIENT IS CONSCIOUS, GIVE A LARGE
QTY OF WATER/MILK.
===================== Fire Fighting Measures =====================
Flash Point:NOT COMBUSTIBLE
Extinguishing Media:APPROPRIATE TO SURROUNDING FIRE CONDITIONS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA. WIPE UP AND PUT INTO A SEALED
CONTAINER FOR PROPER DISPOSAL. WASH SPILL SITE OFF W/WATER AFTER
MATERIAL PICK-UP IS COMPLETE. WEAR CHEMICAL RESISTANT GLASSES,
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE. KEEP
TIGHTLY SEALED WHEN NOT IN USE. IRRITANT.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:CHEMICAL FUME HOOD.
Other Protective Equipment:LAB COAT. HAVE IMMED AVAILABILITY OF AN ANSI
APVD EYE WASH IN CASE OF EMERGENCY. ANSI APVD DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER. EYE PROT: FULL
LENGTH FACESHIELD .
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:1
Solubility in Water:SOLUBLE
Appearance and Odor:TRANSPARENT SOLUTION W/OUT AN ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS. AVOID CONT OF THIS SOLN W/GLASS SINCE FUORIDES ARE PRESENT IN
SOLN WHICH MAY CAUSE DESTRUCTION OF GLASS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY RELEASE TOXIC FUMES OF AMMONIA AND
FLUORINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT LOCAL HAZARDOUS OR CHEMICAL WASTE
DISPOSAL AGENCY FOR REGULATIONS. DISPOSE OF I/A/W FEDERAL, STATE
AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LACQUER, AEROSOL 13538 YELLOW
CAGE:59581
CAGE:59581
============= Composition/Information on Ingredients =============
Ingred Name:VM&P NAPHTHA
RTECS #:ZB1600000
Fraction by Wt: 6.36%
ACGIH TLV:300 PPM
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 17.9%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 2.26%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYLENE CHLORIDE(DICHLOROMETHANE) (SARA III)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 22.4%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM; Z-2
ACGIH TLV:50 PPM, A2; 9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:INHALATION-IRRITATE RESP. TRACT;
HEADACHE,DIZZINESS,CONFUSTION MAY BE EYE IRRITANT.
======================= First Aid Measures =======================
First Aid:FUMES-REMOVE FROM EXPOSURE, RESTORE BREATHING, NOTIFY
PHYSICIAN. EYES-FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST 15
MON. GET MEDICAL TREATMENT IMMEDIATELY. SKIN. WASH WITH SOAP &
WATER. REMOVE C ONTAMINATED CLOTHING.
===================== Fire Fighting Measures =====================
Flash Point:-10F, AEROSOL
Extinguishing Media:CO2, DRY CHEMICAL OR FOAM
CONTAINED RESPIR
Unusual Fire/Explosion Hazard:EXPOSURE TO HEAT MAY CAUSE AEROSOL CAN TO
BURST
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION, AVOID BREATHING
VAPORS, VENTILATE AREA. WIPE UP WITH INERT MATERIALS & PLACE IN
APPROPRIATE CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. EXPOSURE TO
HEAT OR PROLONGED EXPOSURE TO SUN MAY CAUSE BURSTING.
Other Precautions:USE ONLY AS DIRECTED. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING VAPOR & INHALING CAN BE HARMFUL OR
FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID CONTINUOUS BREATHING OF VAPORS & SPRAY
MIST.
Ventilation:USE WITH ADEQUATE VENTILATION.
Supplemental Safety and Health
CONTRACT NO. TC-GS-10F-46124
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:NA
Vapor Density:>AIR
Evaporation Rate & Reference:>ETHER
Percent Volatiles by Volume:85
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:OPEN FLAME
Hazardous Decomposition Products:CO, OXIDES OF NITROGEN, & PHOSGENE
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE AEROSOL. DISPOSE OF IN
ACCORDANCE WITH LOCAL, STATE & FEDERAL REGULATIONS. DO NOT PLACE
AEROSOL CANS IN HOME COMPACTOR. DO NOT PUNCTURE CANS
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LASER TONER CARTRIDGE, 47000000 (470)
CAGE:FGRAP
CAGE:FGRAP
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE ACRYLATE COPOLYMER
CAS:25153-46-2
Fraction by Wt: 55-60%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:IRON OXIDE
CAS:1317-61-9
Fraction by Wt: 30-40%
OSHA PEL:10 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:DYE; (METAL AZO DYE)
CAS:84179-66-8
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLYOXYPROPYLENE GLYCOL; (POLYOLEFIN WAX)
CAS:25322-69-4
RTECS #:TR5250000
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICON DIOXIDE; (SILICA)
CAS:68611-44-9
Fraction by Wt: 0-1%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC: NONE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. INHALATION:
REMOVE FROM EXPOSURE. SKIN: WASH WITH SOAP AND WATER. INGESTION:
DRINK SEVERAL GLASSES OF WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . AVOID BREATHING SMOKE.
Unusual Fire/Explosion Hazard:EXCESS DUST IN AIR CAN FORM EXPLOSIVE
MIXTURE; COMBUSTIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NONE.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:>248F,>120C
Spec Gravity:1.5-1.7(H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:FINE BLACK POWDER, WITH RESIN ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION ARE TOXIC.
AVOID SMOKE INHALATION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE. DISPOSE OF IN ACCORDANCE
W/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-G-10924#10779-2;GREASE
Preparer's Name:THOMAS G. MUSILLI
CAGE:EO110
CAGE:60226
CAGE:EO110
============= Composition/Information on Ingredients =============
Ingred Name:CALCIUM 12 HYDROXYSTEARATE (PER MFR & EPA-TSCA INITIAL
INVENTORY)
CAS:3159-62-4
Fraction by Wt: 11.0%
Ingred Name:MINERAL OIL (PER MFR & EPA-TSCA INITIAL INVENTORY)
CAS:64741-53-3
RTECS #:PY8034000
Fraction by Wt: 86.0%
Other REC Limits:5MG/CUM,AS OIL MIST
Ingred Name:SULFURIZED ISOBUTYLENE
CAS:68511-50-2
Fraction by Wt: 1.0%
Ingred Name:CALCIUM SULFONATE (PER MFR & EPA-TSCA INITIAL INVENTORY)
CAS:68783-96-0
Fraction by Wt: 2.0%
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS NOT AVAILABLE
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE:MAY BE MILDLY IRRITATING.
SKIN: DURING HIGH PRESSURE USAGE MAY RESULT IN INJECTION OF OIL
INTO THE SKIN CAUSING LOCAL NECROSIS. INHALATION:NOT EXPECTED TO BE
A RELEVANT ROUTE OF EXPOSURE; H IGH TEMPERATURE VAPORS IRRITATE
RESPIRATORY TRACT. INGESTION:LOW LEVEL OF TOXICITY. CHRONIC: SKIN
DISORDERS.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:DIRECT CONTACT WITH EYES AND SKIN MAY CAUSE
SLIGHT TO MILD IRRITATION. IF INVOLVE IN COMBUSTION, MAY PRODUCE
TOXIC GASES WHICH MAY CAUSE INHALATION PROBLEMS. ACCIDENTAL
INGESTION OF GREASE MAY CAUSE D IARRHEA, VOMITING AND STOMACH
UPSET.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS MAY BE
AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYE: FLUSH WITH WATER FOR 15
MINUTES WHILE HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION. SKIN:
WASH WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. IF
IRRITATION PER SISTS, GET MEDICAL ATTENTION. INGESTION: DO NOT
INDUCE VOMITING. IN GENERAL, NO TREATMENT IS REQUIRED. GET MEDICAL
ADVICE.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:300F,149C
Autoignition Temp:Autoignition Temp Text:330F
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY. CONTAIN RUNOFF.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:USE APPROPRIATE PROTECTIVE & SAFETY GEARS.
SMALL SPILL:SCOOP UP AND PLACE IN DISPOSAL CONTAINER.CLEAN SURFACE
WITH SUITABLE SOLVENT. LARGE SPILL:ABSORB WITH SUITABLE
ABSORBENT.SHOVEL UP ABSORBED GREAS E INTO DOT SALVAGE DRUMS.CLEAN
SURFACE WITH SOLVNT
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN
USE. KEEP AWAY FROM OPEN FLAMES & HIGH TEMPERATURES.
Other Precautions:MINIMIZE SKIN CONTACT. WASH WITH SOAP & WATER BEFORE
EATING, DRINKING, SMOKING OR USING TOILET FACILITIES. LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE. PROPERLY DISPOSE OF
CONTAMINATED LEATHER ARTICLES (SHOES) THAT CAN NOT BE
DECONTAMINATED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC
VAPORS/MIST IF ABOVE TLV/PEL.
Ventilation:LOCAL/GENERAL TO MAINTAIN AN ADEQUATE VENTILATION.
Other Protective Equipment:PROTECTIVE CLOTHING AND EYE-WASH.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
DO NOT GET IN EYES OR ON CLOTHING.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:650F,343C
Melt/Freeze Pt:M.P/F.P Text:300F,149C
Spec Gravity:0.91
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER SEMI-SOLID GREASE-BLAND
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXTREMELY HIGH TEMPERATURES
Hazardous Decomposition Products:A MIXTURE OF AIRBORNE SOLID, LIQUID
PARTICULATES AND GASES (CO) WILL EVOLVE WHEN THIS MATERIAL
UNDERGOES COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN APPROVED INCINERATOR OR DISPOSE OF
IN APPROVED CHEMICAL DUMP IN ACCORDANCE WITH LOCAL,STATE & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:VULKEN 200,BLACK,6-54-120-00
CAGE:94836
CAGE:94836
============= Composition/Information on Ingredients =============
Ingred Name:COAL TAR CONDENSATION RESIN
Fraction by Wt: 70.0%
Ingred Name:URETHANE OLIGOMER (CAS NO. 31210990)
Fraction by Wt: 15.0%
Ingred Name:URETHANE OLIGOMER (CAS NO. 30653133)
Fraction by Wt: 10.0%
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: < 5%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE-2,4-DIISOCYANATE (TDI) (SARA III)
CAS:584-84-9
RTECS #:CZ6300000
Fraction by Wt: <0.5%
OSHA PEL:C,0.02 PPM/0.02 STEL
ACGIH TLV:0.005PPM/0.02STEL;93
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Effects of Overexposure:CAUSES SLIGHT EYE & SKIN IRRIT. PULMONARY
SENSITIZ CAN OCCUR IN SOME INDIV.-POSSASTHMA TY SPASMS
======================= First Aid Measures =======================
First Aid:CONTAINS COAL TAR, AVOID SKIN CONTACT. IN CASE OF
CONTACT,WASH THOROUGHLY W/SOAP & WATER. OBTAIN MEDICAL ATTN. IMMED.
===================== Fire Fighting Measures =====================
Flash Point:155F
Lower Limits:1.1
Extinguishing Media:FOAM, CO*2, SAND, DRY CHEMICAL, WATERSPRAY, WATER
FOG
PROTECTIVE CLOTHING
Unusual Fire/Explosion Hazard:FIRE:MOD. WHEN EXPOS TO HEAT. EXPLOS:
MOD. EXPOS TO HEAT/FLAME-POSS TDI POLYMERIZATION.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP IN ABSORBENT MATERIAL & DISPOSE IN
VENTED CONTAINER
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT AGAINST PHYSICAL DAMAGE.STORE
AWAY FROM HEAT OR FLAME. KEEP CONTAINER CLOSED WHEN NOT IN USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD RESP W/ORGANIC VAPOR
CARTRIDGES MAY BE USED (MFR)
Ventilation:LOCAL EXHST OR GEN MECH SUFFICIENT TO PREVENT VAPOR ACCUM
Other Protective Equipment:PROTECTIVE CLOTHING
Supplemental Safety and Health
DOT CATEGORY: COMBUSTIBLE.WT PER GAL: 9.35 LB. KEY1:F8
================== Physical/Chemical Properties ==================
HCC:V4
NRC/State Lic Num:N?A
Vapor Density:>1.0
Evaporation Rate & Reference:SLOWER THAN ETHER.
Percent Volatiles by Volume:25
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER,ALCOHOLS, AMINES, NH*3,CARBOXYLIC ACIDS.
Stability Condition to Avoid:TEMP OF 200C OR
HIGHER,HEAT,FIRE,FLAME,STRNG ACID,OXID AGENT
Hazardous Decomposition Products:FLAM HYDRCRBNS,NOTROGEN OXIDE,
HYDROGEN CYANIDE, CO*2
Conditions to Avoid Polymerization:CONTAM W/SODIUM HYDROXIDE, AMINES,
ALKALINE MATRL,HIGH TEMP.
==================== Disposal Considerations ====================
Waste Disposal Methods:MFR RECM INCINERATION OR LANDFILL IAW FED, STATE
& LOCAL CODES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CUTTING FLUID
CAGE:63400
CAGE:63400
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM LUBRICATING OIL WITH LARD SULFUR ADDITIVE-MFR
STATES NOT HAZARDOUS-
Fraction by Wt: 100%.
ACGIH TLV:5MG/CUM(MIST)
===================== Hazards Identification =====================
Effects of Overexposure:EYES:IRR;SKIN:DRYNESS,IRR,DERMAT.
======================= First Aid Measures =======================
First Aid:SKIN:WASH WITH SOAP AND WATER. EYES: FLUSH WITH WATER.
INHALED: REMOVE TO FRESH AIR. REMOVE CONTAMINATED CLOTHING.
===================== Fire Fighting Measures =====================
Flash Point:399F,204C,COC
Lower Limits:0.9
Upper Limits:7
Extinguishing Media:CO*2, FOAM, DRY CHEM & H*2O FOG.
Fire Fighting Procedures:USE WTR SPRAY TO KEEP FIRE EXPSD.CONT.COOL-SEE
SUPPL.DATA/
Unusual Fire/Explosion Hazard:MINIMIZE BREATHNG GASES-USE SCBA FOR
ENCLOSED OR CONFINED SPACES.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES,VENTILATE AREA
WELL.ABSORB WITH VERMICULITE OR OTHER MATLS., SUCH AS
SAWDUST,RAGS,PAPER & PLACE IN CLOSED CONTAINER. USE NON SPARKING
TOOLS. WEAR PROPER PROTECTIVE EQUIP.DURINGCLEAN UP.KEEP OUT OF
SEWERS BY DIKNG/IMPOUNDING.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY WELL VENTED LOW FIRE
RISK AREA. PROTECT FROM HEAT,SHOCK,FRICTION. KEEP CONTAINERS
CLOSED.AVOID/MINIMIZE SKIN CONTACT.
Other Precautions:WASH THOROUGHLY BEFORE EATING,SMOKING,USING TOILET
FACILITIES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL REQMNTS UNDER ORDINARY
CONDITIONS/ADEQUATE VENT.
Ventilation:NORMAL ROOM VENTILATION.
Other Protective Equipment:FULL WORK CLOTHING TO PREVENT REPEATED OR
PROLONGED CONTACT.
Supplemental Safety and Health
MSDS DATED 09-15-86/
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:555F,291C
Vapor Pres:<1
Vapor Density:>1
Spec Gravity:0.89
Evaporation Rate & Reference:<1
Solubility in Water:NEGL
Appearance and Odor:DARK COLOR-HARSH ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER (WILL NOT REACT VIOLENTLY);OXIDANTS.
Stability Condition to Avoid:AVOID HIGH TEMPS-FLASH POINT=399F
Hazardous Decomposition Products:PARTIAL BURNING PRODUCES
FUMES,SMOKE,ALDEHYDES,CO
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-C-85285B, 35450, TYPE I (03BL162)
Kit Part:Y
Preparer's Name:MIKE SMITH
CAGE:33461
CAGE:33461
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA 313) (CERCLA)(VP = 22 @ 68F)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <1.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM/STEL 150
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:N-BUTYL ACETATE (VP = 13 @ 68F)
CAS:123-86-4
RTECS #:SA7875000
Fraction by Wt: <5.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:150 PPM/STEL 200
ACGIH TLV:150 PPM/STEL 200
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ANTI MAR AGENT
Fraction by Wt: <1.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:XYLENE (SARA 313) (CERCLA) (VP = 21 @ 100F)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: <1.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:150 PPM/STEL 150
ACGIH TLV:150 PPM/STEL 150
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE (SARA 313)(VP = 7.1 @ 68F)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: <1.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM/STEL 125
ACGIH TLV:100 PPM/STEL 125
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL-3-ETHOXYPROPIONATE (VP = 0.7 @ 68F)
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: 5.0%
Other REC Limits:50 PPM/STEL 100
Ingred Name:DIBUTYLTIN DILAURATE (VP = 0.2 @ 320F)
CAS:77-58-7
RTECS #:WH7000000
Fraction by Wt: <0.1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG/M3: STEL 0.1
Ingred Name:VOC = 447 G/L
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
Ingred Name:FLOW AGENT
CAS:26376-86-3
Fraction by Wt: <1.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:2-4 PENTANEDIONE (VP = 6.9 @ 68F)
CAS:123-54-6
RTECS #:SA1925000
Fraction by Wt: <5.0%
Other REC Limits:*UNION CARBIDE)
ACGIH TLV:20 PPM (RECOM. BY*
Ingred Name:ANTI-FLOAT AGENT
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:METHYL ISOBUTYL KETONE (HEXONE)(SARA 313)(CERCLA) (VP = 15
@ 68F)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 20.07%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:50 PPM/ 75 STEL
ACGIH TLV:50 PPM/ 75 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE)(MEK)(SARA 313)(CERCLA) (VP
= 70 @ 68F)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 2.34%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM STEL 300
ACGIH TLV:200 PPM STEL 300
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: IRRITAT OF RESPIRATORY TRACT.
NS DEPRESSION (HEADACHE/DIZZY/STAGGERING
GAIT/CONFUSION/UNCONSIOUS/COMA). SKIN:
IRRITAT/SWELLING/REDNESS/RASH. EYE:
IRRITAT/TEARING/REDNESS/SWELLING/STINGING. INGE ST:
IRRIAT/VOMIT/CHEMICAL PNEUMONITIS. CORROSIVE (MOUTH/STOMACH
TISSUE/DIGESTIVE TRACT).
Effects of Overexposure:CHRONIC: SKIN IRRITAT, DRYING, DEFATTING,
CRACK, SENSITIZATION. INHALE DIFFICULT BREATHING. ASTHMA OR OTHER
ALLERGIC REACTIONS.
Medical Cond Aggravated by Exposure:ASTHMA & OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA & DERMITITS.
======================= First Aid Measures =======================
First Aid:INHAL: GET FRESH AIR. SYMPTOMS MAY BE DELAYED. GET MED AID.
SKIN: REMOVE CLOTHES. WASH W/SOAP & WATER. WASH CLOTHES BEFORE
REUSE. EYE: FLUSH W/WARM WATER FOR 15 MIN, LIFT LIDS. GET MED AID.
INGEST: DO NT INDUCE VOMIT. GET MED AID.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:23.0F,7.2C
Lower Limits:0.76
Upper Limits:11.4
Extinguishing Media:FOAM, ALCOHOL-FOAM, CARBON DIOXIDE, DRY CHEMICAL,
WATER FOG, WATER SPRAY.
Fire Fighting Procedures:FULL EQUIPMENT W/SCBA, FULL PROTECTIVE
CLOTHING. USE WATER TO COOL CLOSED CONTAINERS TO PREVENT PRESSURE
BUILD-UP, AUTOIGNITION, EXPLOSION.
Unusual Fire/Explosion Hazard:KEEP CLOSED TIGHT. CLOSED CNTNR MAY
EXPLODE W/EXTREME HEAT. APPLICATION TO HOT SURFACES USE SPECIAL
PRECAUTIONS. POS HEALTH HAZ W/OVEREXPOSURE DECOMP PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. VENTILATE AREA.
CONTAIN & REMOVE INERT ABSORBENT W/NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COMPLIANCE W/OSHA 1910.106.
AVOID HIGH TEMPERATURES, IGNITION SOURCES. STORE IN TIGHTLY CLOSED
CONTAINERS. VENTILATED AREAS.
Other Precautions:KEEP CONTAINERS TIGHT IN UPRIGHT, TO PREVENT LEAKAGE.
DONT HANDLE UNTIL MANUFACTURERS SAFTY PRECAUTIONS HAVE BEEN
UNDERSTOOD. SMOKE IN SMOKING AREAS ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ORGANIC VAPOR (AIR PURIFYING OR FRESH AIR
SUPPLIED)
Ventilation:EXHAUST VENTILATION
Other Protective Equipment:*WITH SPLASH GUARDS, SIDE SHIELDS. USE LONG
SLEEVE & LEG CLOTHES.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, USING
BATHROOM.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:175 TO 401F
Vapor Density:>AIR
Spec Gravity:1.2401
pH:NA
Viscosity:**
Evaporation Rate & Reference:1.24 (BUAC=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:GRAY LIQUID W/SOLVENT ODOR
Percent Volatiles by Volume:53.1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPS, SPARKS, OPEN FLAMES.
Hazardous Decomposition Products:CABON MONOXIDE, CARBON DIOXIDE, OXIDES
OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE W/FEDERAL, STATE & LOCAL
REGULATIONS. EMPTY CONTAINERS HAVE RESIDUE & FLAMMABLE VAPORS.
DONT INCINERATE CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ENAMEL, NONFLAMING (DRY) CHLORINATED ALKYD SEMI-GLOSS
CAGE:1BH90
CAGE:SO007
CAGE:1BH90
============= Composition/Information on Ingredients =============
Ingred Name:BARIUM METABORATE
CAS:13701-59-2
Fraction by Wt: 15.0%
Other REC Limits:5 MG/M3
OSHA PEL:TOTAL DUST
ACGIH TLV:TOTAL DUST
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 21.0%
Other REC Limits:10 MG/M3
OSHA PEL:TOTAL DUST
ACGIH TLV:TOTAL DUST
Ingred Name:ZINC PHOSPHATE
CAS:7779-90-0
RTECS #:TD0590000
Fraction by Wt: 16.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYMER BASE CHLOROENDIC ALKYLOID
RTECS #:BP1008526
Code:F
Fraction by Wt: 35.0%
Ingred Name:TRADE SECRET: REGISTRY #41-0177680-5000 381 P (NJAPA)
RESIN SOLUTION
RTECS #:RS1010182
Code:F
Ingred Name:PAINT THINNER
CAS:8052-41-3
Fraction by Wt: 9.0%
OSHA PEL:100 PPM TWA
ACGIH TLV:100 PPM TWA
Ingred Name:DRIERS
CAS:136-52-7
Fraction by Wt: 3.0%
Ingred Name:LEVELING AGENT
RTECS #:LA1001685
Code:F
Ingred Name:ANTISKINNING AGENT
Fraction by Wt: 1.0%
Ingred Name:THIXATROPIC AGENT
RTECS #:TA1000608
Code:F
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:ACUTE: EYES: SEVERE IRRITATION. SKIN:
PRIMARY IRRITATION. HARMFUL IF ABSORBED THRU SKIN.
PROLONGED/REPEATED CONTACT: ALLERGIC SKIN REACTION. INHAL: HARMFUL
IF INHALED. IRRITATES EYES/NOSE/THROAT & LU NGS. HIGH VAPOR
CONCENTRATIONS MAY CAUSE IRRITATION OF RESPIRATORY SYSTEM &
PERMANENT BRAIN/NERVOUS SYSTEM DAMAGE. INTENTIONAL MIUSE CAN BE
HARMFUL OR FATAL. CHRONIC: AVOID LONG TERM/REPEATED CONTACT .
Explanation of Carcinogenicity:SEE TOXICOLOGICAL SECTION FOR DETAILS
Effects of Overexposure:EYE WATERING, HEADACHES, NAUSEA, DIZZINESS,
LOSS OF COORDINATION ARE INDICATIONS THAT SOLVENT LEVELS ARE TOO
HIGH. REDNESS/ITCHING/BURNING SENSATION/VISUAL DISTURBANCES MAY
INDICATE EXCESSIVE EYE CONT ACT. DRINESS/ITCHING/CRACKING/BURNING
REDNESS/SWELLING: EXCESSIVE SKIN CONTACT.
======================= First Aid Measures =======================
First Aid:IF SWALLOWED: GIVE 1 OR 2 GLASSES OF WATER. DO NOT INDUCE
VOMITING. KEEP PERSON WARM, QUIET, AND GET IMMED MEDICAL ATTEN.
EYES: FLUSH WITH WATER FOR 30 MINUTES, LIFTING LIDS TO RINSE ENTIRE
EYE. CALL DR IMMED. SKIN: FLUSH W/COPIOUS AMOUNTS OF WATER, THEN
FOLLOW W/ SOAP & WATER. CALL DR. INHALATION: REMOVE TO FRESH AIR.
APPLYSUPPORTIVE MEASURES AS REQUIRED. OTHER: IF INGEST: ANY TYPE
OF OVEREXPO SURE/SYMPTOMS OF OVEREXPOSURE OCCUR DURING/FOLLOWING
USE OF PRODUCT, CONTACT POISON CONTROL CENTER, EMERENCY ROOM, OR
PHYSICIAN IMMED. HAVE MSDS INFO AVAILABLE.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:=40.6C, 105.F
Autoignition Temp:Autoignition Temp Text:NA
Extinguishing Media:USE NATIONAL FIRE PROTECTION ASSOCIATION (NFPA)
CLASS B EXTINGUISHERS (FOAM, CO2, DRY CHEMICAL) DESIGNED TO
EXTINGUISH NFPA CLASS IC FLAMMABLE LIQUID FIRE.
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. WATER SPRAY
MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT PRESSURE BUILD UP
AND POSSIBLE AUTOIGNITION OR EXPLOSION WHEN EXPOSED TO EXTREME
HEAT. IF WATER IS USED, FO G NOZZLES ARE PREFERABLE. FIRE FIGHTERS
WEAR SCBA.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS, OPEN FLAMES. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT. DO NOT APPLY
ON HOT SURFACES. TOXIC GASES MAY FORM WHEN PRODUCT IS CONTACTED BY
FLAME OR HOT SURFACES.
================== Accidental Release Measures ==================
Spill Release Procedures:PROVIDE MAXIMUM VENTILATION. ONLY PERSONEL
AREA. REMOVE ALL SOURCES OF IGNITION. PICK UP SPILLED MATERIAL
W/SAWDUST, VERMICULITE, OR OT HER ABSORBENT & PLACE INTO CONTAINERS
FOR DISPOSAL.
======================Handling and Storage ======================
Other Precautions:
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ENSURE VENTILATION CONTROLS, VAPOR EXHAUST, OR
FRESH AIR ENTRY. NIOSH/MSHA APPROVED 9TC-23C AIR PURIFYING OR AIR
SUPPLIED TC-19C RESPIRATORS MAY ALSO REDUCE EXPOSURE.
Ventilation:GENERAL DILUTION OR LOCAL EXHAUST VENTILATION IN VOLUME AND
PATTERNED TO KEEP INGREDIENTS BELOW SUGGESTED LIMITS IN THIS MSDS.
Other Protective Equipment:CLEAN OR DISCARD CONTAMINATED CLOTHING AND
SHOES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:>154.4C, 310.F
B.P. Text:310-390 F AT 760 MM HG
Vapor Pres:2.000 MMHG AT 68 F
Vapor Density:4.9
Spec Gravity:1.62-1.65
VOC Pounds/Gallon:340
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG ALKALIS, STRONG MINERAL ACIDS, OR STRONG
OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID CONTACT WITH STRONG ALKALIS, STRONG
MINERAL ACIDS, OR STRONG OXIDIZING AGENTS.
===================== Ecological Information =====================
Ecological:THIS PRODUCT CONTAINS A LOW LEVEL OF FORMALDEHYDE ON THE
BASIS OF LONG TERM EXPOSURE OF ANIMALS TO HIGH LEVELS NTP, IARC,
AND OSHA ASSOCIATE FORMALDEHYDE WITH AN INCREASED RISK OF CANCER.
RECENT STUDI ES WITH HUMANS SHOW NO CORRELATION BETWEEN EXPOSURE TO
FORMALDEHYDE AND INCREASED CANCER RISK.
==================== Disposal Considerations ====================
Waste Disposal Methods:
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:5255-5315 COLORLITH
Preparer's Name:DICK KARBO
CAGE:KMADD
CAGE:KMADD
============= Composition/Information on Ingredients =============
Ingred Name:COPPER COMPOUND
Fraction by Wt: 3%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED CONTACT W/SKIN/EYES CAN
CAUSE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMEDIATELY W/WATER. SKIN: WASH AFFECTED AREA
W/SOAP & WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>200F
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: WIPE UP & STORE WIPERS IN UNDERWRITERS
APPROVED CONTAINERS. LARGE: SCOOP MATERIAL INTO SEALABLE
CONTAINERS. WIPE UP REMAINDER & STORE WIPERS IN UNDERWRITERS
APPROVED CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS.
Other Precautions:AVOID CONTACT W/SKIN, EYES & CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS REQUIRED
Ventilation:LOCAL EXHAUST
Work Hygienic Practices:WASH AFTER USE. REMOVE/LAUNDER CONTAMINATED
CLOTHING BEFORE REUSE. DON'T CONSUME FOOD/BEVERAGE WHERE PRODUCT IS
USED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:470-610F
Evaporation Rate & Reference:SLOWER THAN WATER
Solubility in Water:INSOLUBLE
Appearance and Odor:OILY
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: CALCIUM HYPOCHLORITE GRANULAR, LACCO
Cage: 75656
=======================================================
Contractor Summary
=======================================================
Cage: 75656
Box: 1987
=======================================================
Ingredients
=======================================================
Cas: 7778-54-3
RTECS #: NH3485000
% Wt: 65-75
OSHA PEL: 0.5 PPM (CL)
ACGIH TLV: 0.5 PPM;1 STEL (CL)
EPA Rpt Qty: 10 LBS
DOT Rpt Qty: 10 LBS
------------------------------
Cas: 7647-14-5
RTECS #: VZ4725000
% Wt: 10-20
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 10137-74-3
RTECS #: FN9800000
% Wt: 0-5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 10043-52-4
RTECS #: EV9800000
% Wt: 0-5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 1305-62-0
RTECS #: EW2800000
% Wt: 0-4
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 5 MG/M3
------------------------------
Cas: 471-34-1
RTECS #: FF9335000
% Wt: 0-4
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 7732-18-5
RTECS #: ZC0110000
% Wt: 0-5.5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
ENTIRE GI TRACT, INCL STOMACH & INTESTINES,
-----------------------------
ULCERATION. THERE ARE NO KNOWN/REPORTED
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYE CONT:SEV IRRIT &/OR BURNS CAN OCCUR FOLLOWING
EXPOS. CONT MAY CAUSE IMPAIRMENT OF VISION & CORNEAL DMG. SKIN
CONT:DERMAL EXPOS CAN CAUSE SEV IRRIT &/OR BURNS CHARACT BY REDNESS,
SWELL & SCAB FORM. PRLNG EXPOS MAY CAUSE DESTRUCT OF DERMIS W/IMPAIRMENT
OF SKIN AT SITE OF CONT TO REGENERATE. EFTS FROM(EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:CHRONIC EXPOS WOULD BE SIMILAR TO
THOSE FROM SINGLE EXPOS EXCEPT FOR EFTS SECONDARY TO TISS DESTRUCT.
INHAL:INHAL OF MATL IS IRRIT TO NOSE, THROAT & LUNGS. IT MAY ALSO CAUSE
BURNS TO RESP TRA CT W/PRODUCTION OF LUNG EDEMA WHICH CANRSLT IN SHORTNESS OF
BREATH, WHEEZING, CHOKING, CHEST PAIN & IMPAIRMENT (SUPDAT)
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES:IMMED FLUSH W/LG AMTS OF WATER FOR AT LST 15 MINS, OCCAS
LIFTING UPPER & LOWER LIDS. CALL MD AT ONCE. SKIN:IMMED FLUSH W/WATER FOR
AT LST 15 MINS. CALL MD. IF CLTHG COMES IN CONT W/PROD, CLTHG SH OULD BE
LAUNDERED BEFORE RE-USE. INHAL:REMOVE VICTIM TO FRESH AIR. SUPPORT RESP IF
NEEDED, CALL MD. INGEST:IMMED DRINK LG QTYS OF WATER. DO NOT INDUCE VOMIT.
CALL MD AT ONCE. DO NOT GIVE (SUPP DATA)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: CONTAINERIZE ALL VIRGIN MATL IN CLEAN, DRY CNTNR
USING ONLY CLEAN DEDICATED EQUIP TO CLEAN MATL UP. CONTAINERIZE ALL CONTAM
MATL IN CLEAN, DRY CNTNR & REMOVE TO WELL VENTED AREA BEING SURE TO NOT
SEALTIGHTLY. CONTAM SPILL MATL MAY BECOME HAZ WASTE.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: IT MUST BE DISPOSED OF I/A/W LOCAL, STATE & FEDERAL
REGULATIONS IN A PERMITTED HAZARDOUS WASTE TREATMENT, STORAGE & DISPOSAL
FACILITY TREATMENT.
Handling And Storage Precautions: DO NOT TAKE INTERNALLY. AVOID CONTACT W/EYES,
SKIN OR CLOTHING. KEEP CONTAINERS TIGHTLY SEALED. STORE IN A CLEAN, DRY,
WELL-VENTILATED AREA.
Other Precautions: DO NOT STORE AT TEMPERATURES ABOVE 52C.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: MEDIA SUITABLE FOR SURROUNDING FIRE (FP N).
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). USE WATER TO COOL CONTAINERS EXPOSED TO FIRE. DO NOT USE
EXTINGUISHERS CONTAINING AMMONIUM CMPDS.
Unusual Fire/Explosion Hazard: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF
CONCERN (FP N).
Ventilation: NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: UPON CONTACT W/SKIN OR EYES, WASH OFF W/WATER.
Supplemental Safety and Health: PH:10.5-11.5 (1% SOLN). MATLS TO AVOID:CORR,
FLAMM/COMBUST MATLS. FIRST AID PROC:ANYTHING BY MOUTH IF PERS IS UNCON/IF
HAVING CONVLS. EYE PROT:& FULL LGTH FSHLD (FP N). EFTS OF OVEREXP:OF LUNG
FUNC. I NHAL OF HIGH CONCS CAN RSLT IN PERM LUNG DMG. CHRONIC (RPTD) INHAL
EXPOS MAY CAUSE IMPAIRMENT OF LUNG FUNC & PERM
=======================================================
Physical/Chemical Properties
=======================================================
PH: SUPDAT
Solubility in Water: APPROX 18% @ 25C
Appearance and Odor: WHITE, FREE FLOWING GRANULES OR TABLET FORM PRODUCT;
CHLORINE LIKE ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: NO
Stability Condition To Avoid: HIGH TEMPERATURES >125F, HIGH HUMIDITY.
Materials To Avoid: ACIDS, ORGANICS, NITROGEN CONTAINING CMPDS, DRY POWDER,
FIRE EXTINGS (CONTAINING MONO-AMMONIUM PHOSPHATES), (SUPP DATA)
Hazardous Decomposition Products: CHLORINE GAS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: CALCIUM HYPOCHLORITE GRANULAR, LACCO
Cage: 75656
Company Name: LOS ANGELES CHEMICAL CO
Street: 4545 ARDINE ST
PO Box: 1987
Zipcode: 90280
Label Required IND: Y
Date Of Label Review: 08/03/1998
Status Code: C
Label Date: 08/03/1998
Origination
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Severe
Contact Hazard: Severe
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE:EYE CONTACT:SEVERE IRRITATION AND/OR BURNS CAN
OCCUR FOLLOWING EXPOSURE. CONTACT MAY CAUSE IMPAIRMENT OF VISION AND CORNEAL
DAMAGE. SKIN CONTACT:DERMAL EXPOSURE CAN CAUSE SEVERE IRRITATION AND/O R
BURNS CHARACTERIZED BY REDNESS, SWELLING AND SCAB FORMATION. PROLONGED
EXPOSURE MAY CAUSE DESTRUCTION OF DERMIS WITH IMPAIRMENT OF SKIN AT SITE OF
CONTACT TO REGENERATE. INHALATION:IRRITATION OR BUR NS TO RESPIRATORY TRACT.
INGESTION:IRRITATION OR BURNS TO GASTROINTESTINAL TRACT, ULCERATION, NAUSEA,
VOMITING. CHRONIC:LUNG DAMAGE.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RUST EATER OIL/ALKYD GLOSS ENAMEL, 5709 (SU
CAGE:85231
CAGE:59019
CAGE:85231
============= Composition/Information on Ingredients =============
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (MINERAL SPIRITS). VP:
2
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 0-45%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:MINERAL SPIRITS; (MINERAL SPIRITS 140-FLASH). VP: 0.5
CAS:64742-88-7
Fraction by Wt: 0-50%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:ETHYLENE GLYCOL. VP: 0.1
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 0-5%
OSHA PEL:50 PPM, C
ACGIH TLV:50 PPM,VAPOR, C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE).
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 0-25%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:WASTE DISP METH: INCINERATE CLOSED CONTAINER. DISP OF I/A/W
FEDERAL, STATE AND LOCAL REGULATIONS REGARDING POLLUTION.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP: HAVE ASSOC RPTD & PRLNG OVEREXP TO
SOLVENTS WITH PERMANENT BRAIN & NERVOUS SYS DMG. HDCHE, (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: DIZZ, NAUSEA & LOSS OF COORDINATION ARE INDICATIONS
OF EXCESS EXPOS TO VAPS/SPRAY MIST. REDNESS & ITCHING (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: OR BURNING SENSATION MAY INDICATE EYE OR EXCESSIVE
SKIN EXPOSURE.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: AVOID CONTACT WITH SKIN AND EYES. THIS COATING
MAY CONTAIN MATLS CLASSIFIED AS NUISANCE PARTICULTES (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: SUCH AS TITANIUM DIOXIDE/CALCIUM CARBONATE, WHICH
MAY BE PRESENT AT HAZ LEVELS ONLY DURING SANDING OR (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: ABRADING OF THE DRIED FILM.
RTECS #:9999999ZZ
Ingred Name:RESP PROT: WEAR NIOSH/MSHA APPROVED PARTICULATE RESP FOR
PROT AGAINST NON-VOLATILE MATLS IN INGRED SECTION.
RTECS #:9999999ZZ
Ingred Name:VENT: BELOW APPLICABLE EXPOSURE LIMITS. REFER TO OSHA
STANDARDS 1910.94, 1910.107, 1910.108.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRIT OF EYES, SKIN & RESP SYS.
MAY CAUSE NERV SYS DEPRESS. EXTREME OVEREXP MAY RSLT IN UNCON &
POSSIBLY DEATH. CHRONIC: ETHYLENE GLYCOL IS CONSIDERED AN ANIMAL
TERATOGEN. IT HAS BEEN SHOWN TO C AUSE BIRTH DEFECTS IN RATS & MICE
AT HIGH DOSES WHEN GIVEN IN DRINKING H*2O/BY GAVAGE. THERE IS NO
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: EVIDENCE TO INDICATE IT CAUSES BIRTH
DEFECTS IN HUMANS. PRLNG OVEREXP TO SOLV INGRED LISTED IN INGRED
SEC MAY CAUSE ADVERSE EFTS TO LIVER & URINARY SYS. RATS EXPOS TO
TITANIUM DIOXIDE DUST @ 250 MG/M3 DEVELOPED LUNG CANCER, HOWEVER,
SUCH EXPOS LEVELS ARE NOT ATTAINABLE IN THE WORKPLACE. REPORTS (ING
6)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE BREATHING.
KEEP WARM AND QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP
AND WATER. EYES: FLUSH EYES WITH LARGE AMOUNTS OF WATER FOR AT
LEAST 15 MIN. GET MEDICAL ATTENTION. INGEST: GETMD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:100F,38C
Lower Limits:0.9 %
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
H*2O SPRAY MAY BE INEFTIVE. IF H*2O IS USED, FOG NOZZ ARE
PREFERABLE. H*2O MAY BE USED TO COOL CLSD (SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT/ELEC EQUIP/SPARKS/OPEN FLAME. CLSD CNTNRS MAY EXPLO WHEN
EXPOS TO EXTREME HEAT. APPLICATION TO HOT SURF (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTENTS ARE COMBUST. KEEP AWAY FROM
HEAT/OPEN FLAME. CONSULT NFPA CODE. USE APPRVD BONDING & GROUNDING
PROCEDURES. KEEP CNTNRS CLSD WHEN NOT IN USE.
Other Precautions:TRANSFER ONLY TO APPRVD CNTNRS W/COMPLETE & APPROP
LABELING. DO NOT TAKE INTERNALLY. KEEP OUT OF THE REACH OF
CHILDREN. INTENTIONAL MISUE BY DELIB CONC & INHALING CONTENTS CAN
BE HARMFUL/FATAL. AVOID BREATHING VAPOR & SPRAY MIST. (ING 9)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIMITS BY VENT, WEAR A PROPERLY FITTED NIOSH/MSHA APPRVD ORG
VAP/PARRTICULATE RESP FOR PROT AGAINST MATLS IN ING SEC. WHEN
SANDING/WIREBRUSHING/ABRA DING/WELDING THE DRIED FILM, (ING 12)
Ventilation:USE ONLY W/ADEQ VENT. LOC EXHST PREFERABLE. GEN EXHST
ACCEPTABLE IF EXPOS TO MATLS IN INGRED SEC IS MAINTAINED (ING 13)
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
MFR TRADE NAME/PART NO: ULTRA DEEP BASE T. EXPLO HAZ: REQUIRES SPECIAL
PREC. DURING EMERGENCY CNDTNS OVEREXP TO DECOMP PROD MAY CAUSE A
HLTH HAZ. SYMP MAY NOT BE IMMED APPARENT. OBTAIN MED ATTENTION.
FIRE FIGHT PROC: CONTAINERS TO PREVENT PRESS BUILD-UP & POSSIBLE
AUTIOIGNITION/EXPLOSION WHEN EXPOSED TO EXTREME HEAT.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:240F,116C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:0.9-1.2
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:49-66
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF METALS IN INGREDIENT SECTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FORM PROD MAY BE HAZ AS DEFINED UNDER RCRA
40 CFR 261. WASTE MUST BE TESTED FOR IGNIT TO DETERMINE THE
APPLICABLE EPA HAZ WASTE NO. WASTE CNTNG CHROMIUM OXIDE (385) MUST
BE TESTED FOR EXTRACTABI LITY. INCIN IN APPRVD FACILITY. DO NOT
(ING 5)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:57213 ANTI-A, B MONOCLONAL ABO SERA
CAGE:67018
CAGE:67018
CAGE:67823
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM AZIDE, AZIDE *98-1*
CAS:26628-22-8
RTECS #:VY8050000
Fraction by Wt: 0.1%
Other REC Limits:0.1 PPM
ACGIH TLV:C 0.29 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 27 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF SWALLOWED. MAY BE ABSORBED
THROUGH SKIN. MAY CAUSE ALLERGENIC REACTION IN SUSCEPTIBLE
INDIVIDUALS.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH THOROUGHLY W/WATER FOR 15 MINS. SKIN: RINSE
W/PLENTY OF WATER FOR 15 MINS. INHALATION: AID IN BREATHING IF
NECESSARY. INGESTION: FLUSH MOUTH. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:DRY CHEMICAL/CO2
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: WEAR PROTECTIVE CLOTHING TO GUARD
AGAINST EYE & SKIN CONTACT. USE SPILL PILLOWS/OTHER APPROPRIATE
ABSORBENT. PLACE MATERIALS IN SEALED CONTAINER FOR PROPER DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BETWEEN 35.6F-46.4F. DON'T STORE
NEAR ACIDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED, UNDER NORMAL PRODUCT USE.
Ventilation:USE W/ADEQUATE VENTILATION.
Other Protective Equipment:CHEMICAL RESISTANT APRON, PROTECTIVE
CLOTHING.
Work Hygienic Practices:GOOD HYGIENE PRACTICES SHOULD BE FOLLOWED TO
AVOID EYE & SKIN CONTACT W/THIS PRODUCT.
Supplemental Safety and Health
WHILE THE PRODUCTS LISTED ARE NOT CONSIDERED HAZARDOUS AS DEFINED BY
OSHA, BCA WOULD LIKE TO MAKE YOU AWARE OF THE FOLLOWING HANDLING
PRECAUTIONS: THESE PRODUCTS CONTAIN 0.1%/LESS SODIUM AZIDE AS A PR
ESERVATIVE. THEREFORE, WE HAVE ENCLOSEDA MSDS FOR 0.1% SODIUM
AZIDE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Vapor Pres:AS WATER
Evaporation Rate & Reference:(WATER=1): 1
Appearance and Odor:COLORLESS LIQUID W/NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS
Hazardous Decomposition Products:TOXIC GAS, MAY FORM EXPLOSIVE
LEAD/COPPER IN LABORATORY PLUMBING
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS. MAY FORM EXPLOSIVE LEAD/COPPER AZIDE IN
LABORATORY PLUMBING.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LIDOCAINE HYDROCHLORIDE INJ.,USP,4903,7931,7939.
CAGE:0ALT7
CAGE:0ALT7
============= Composition/Information on Ingredients =============
Ingred Name:LIDOCAINE HYDROCHLORIDE IN AQUEOUS SOLUTION.
CAS:73-78-9
RTECS #:AN7600000
Other REC Limits:NONE RECOMMENDED
Ingred Name:AQUEOUS SOLUTION
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50=220-457MG/KG,MICE,ORAL.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTAINS LIDOCAINE HYDROCHLORIDE IN
AQU SOLN.HEALTH RELATED DATA FOR PROD BASED ON LIDOCAINE
HYDROCHLORIDE CONTENT.LOC ANESTHETIC THAT PRODUCES NUMBUNESS & THAT
AFFECTS CNS & CARDIOVASCULAR SYSTEM.CAN AFFECT FETUS(FETAL HYPOXIA
OR BRADYCARDIA)IF USED DURING LABOR/DELIVERY.INFREQUENT INDICES
DELAYED HYPERSENSITIVITY RES
Explanation of Carcinogenicity:PER
MSDS:CARCINOGENICITY:NTP/IARC/OSHA/ACGIH:NOT LISTED.
Effects of Overexposure:IN CLINICAL USE PRODUCES
NUMBNESS,LIGHTHEADEDNESS,DROWS,DIZZ,RESTLESSNESS,LOSS OF
HEARING,BREATH/SWALLOWE
DYSFUNCTION,APPREHENSION,EUPHORIA,TINNITIS,ALTERED
VISION,VOMIT,SENSATION OF HOT/COLD NUMBNESS
,TWITCHING,TREMORS,STUPOR,CONVULSIONS,UNCONSC,RESP
ARREST,HYPOTENSION,BRADYCARDIA & CARDIOVASCULAR COLLAPSE.
Medical Cond Aggravated by Exposure:SENSITIVITY TO LOCAL ANESTHETICS.
PRE-EXISTING CARDIOVASCULAR OR CENTRAL NERVOUS SYSTEM DISEASE.
======================= First Aid Measures =======================
First Aid:REMOVE FROM SOURCE OF EXPOSURE. SKIN/EYE CONTACT OCCURS FLUSH
W/COPIOUS AMTS OF WATER. IF IRRIT PERSISTS OR SIGNS OF TOXICITY
OCCUR SEEK MED ATTN. NO KNOWN ANTIDOTE. PROVIDE
SYMPTOMATIC/SUPPORTIVE, MO NITORING CARDIAC & RESP FUNCTION, CARE
AS NECESSARY.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:PER MSDS:N/A. HOWEVER USE APPROPRIATE EXTINGUISHING
MEDIA FOR SURROUNDING FIRE.
Fire Fighting Procedures:NONE.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH SUITABLE MATERIAL. FLUSH WITH
WATER.
Neutralizing Agent:NONE SPECIFIED BY MFG.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED.
Ventilation:NO SPECIAL PROVISIONS REQUIRED.
Other Protective Equipment:N/A.
Work Hygienic Practices:WASH HANDS AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:WATER(APRX)
Melt/Freeze Pt:M.P/F.P Text:WATER(APRX)
Spec Gravity:WATER(APPROX)
pH:3-7
Viscosity:WATER(APPROX)
Solubility in Water:AQUEOUS SOLUTION
Appearance and Odor:CLEAR LIQUID.
Percent Volatiles by Volume:NELGIG
================= Stability and Reactivity Data =================
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NOT DETERMINED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. AS OF REVIEW DATE OF THIS DOCUMENT (MFG'S
MSDS) THIS CHEMICAL IS NOT AN RCRA HAZ WASTE (PER 40CFR PART 261).
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AFC 1-2-3 FOGGING CONCENTRATE
CAGE:14968
CAGE:14968
============= Composition/Information on Ingredients =============
Ingred Name:PYRETHRUM (SARA III)
CAS:8003-34-7
RTECS #:UR4200000
Fraction by Wt: 1.0%
Other REC Limits:N/K
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:PETROLEUM DISTILLATES (NAPHTHA OR RUBBER SOLVENT)
CAS:8002-05-9
RTECS #:SE7449000
Fraction by Wt: 94.0%
Other REC Limits:300 PPM
OSHA PEL:400 PPM
ACGIH TLV:400 PPM; 8990
Ingred Name:TECHNICAL PIPERONYL BUTOXIDE
CAS:51-03-6
RTECS #:XS8050000
Fraction by Wt: 2.0%
Other REC Limits:5 MG/CUM
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:N-OCTYL BICYCLOHEPTENE DICARBOXIMIDE
CAS:463-04-7
RTECS #:RB8575000
Fraction by Wt: 3.0%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS AND SYMPTOMS OF
OVEREXPOSURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:POSSIBLE NERVOUS SYSTEM DISORDERS AND DIARRHEA.
Medical Cond Aggravated by Exposure:N/K
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH WATER FOR AT LEAST 15 MIN.SKIN:WASH FROM SKIN
WITH SOAP AND WATER.INGESTION:TREAT SYMPTOMATICALLY.DO NOT INDUCE
VOMITING.ATROPINE SULFATE CAN CONTROL DIARRHEA.INHALATION:REMOVE TO
FRES H AIR.SUPPORT BREATHING (GIVE O*2/ARTIFICIAL RESPIRATION)
.ANTIHISTAMINES MAY HELP.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:180F,82.22C
Lower Limits:N/K
Upper Limits:N/K
Extinguishing Media:CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .TREAT LIKE OIL FIRE.
Unusual Fire/Explosion Hazard:VAPORS MAY ACCUMULATE IN CONFINED SPACES
(PITS,SEWERS).CONTAINERS MAY EXPLODE IN HEAT OF FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:WASH AREA WITH STRONG ALKALINE SOLUTION.SOAK
UP ON SAWDUST OR OTHER ABSORBENT MATERIAL.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP DRUM CLOSED.STORE IN COOL,DRY
PLACE.DO NOT STORE,USE OR POUR NEAR HEAT OR OPEN FLAME.DO NOT STORE
NEAR FOOD OR FEED.
Other Precautions:N/K
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Other Protective Equipment:WORK CLOTHES.
Work Hygienic Practices:N/K
Supplemental Safety and Health
N/K
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>410F,210C
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Spec Gravity:0.84 (WATER=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER PYRETHRIN ODOR/MILD SOLVENT ODOR;STRAW YELLOW
LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
EXTREMELY ACID OR ALKALINE MATERIALS.
Stability Condition to Avoid:N/K
Hazardous Decomposition Products:N/K
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .LIKE OIL OR RETURN TO CHEMICAL
RECLAIMER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TRINITROTOLUENE (TNT) TYPE 1 FLAKE FORM
CAGE:2D295
CAGE:2D881
CAGE:2D295
============= Composition/Information on Ingredients =============
Ingred Name:2,4,6-TRINITROTOLUENE (TNT)
CAS:118-96-7
RTECS #:XU0175000
Fraction by Wt: 99%
OSHA PEL:S, 1.5 MG/M3
ACGIH TLV:S, 0.5 MG/M3; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ALLERGENIC, CAN CAUSE DERMATITIS.
DISCOLOR SKIN AND HAIR PALE YELLOW. CAUSES NAUSEA, VOMITING AND
ANOREXIA ALSO LIVER AND BLOOD DAMAGE, AND APLASTIC ANEMIA.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:IMEEDIATELY FLUSH THOROUGHLY WITH LARGE AMOUNTS OF LOW
PRESSURE WATER FOR AT LEAST 25 MINUTES. REMOVE CONTACT LENSES TO
ASSURE THOROUGH FLUSHING. CALL MD. SKIN:WASH WITH TNT INDICATOR
SOAP AND RUN NING WATER. INHAL:REMOVE TO FRESH AIR. TREAT ANY
IRRITATION SYMPTOMATICALLY. CALL MD. INGEST:CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point:EXPLODES
Extinguishing Media:DELUGE WITH WATER-USE LARGE QUANTITIES.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . EVACUATE THE AREA.
Unusual Fire/Explosion Hazard:HIGHLY DANGEROUS-SHOCK WILL EXPLODE IT.
WILL DETONATE IF CONFINED AND EXPOSED TO EXTRME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP SPILL IMMEDIATELY USING A SOFT
BRISTLE BRUSH AND A CONDUCTIVE RUBBER OR PLASTIC SHOVEL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR FOR DUSTS.
Ventilation:MECHANICAL (GENERAL) VENTILATION.
Other Protective Equipment:FLAME-PROOF COVERALLS AND CONDUCTIVE SHOES.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:E1
Boiling Pt:B.P. Text:464F,240C
Spec Gravity:1.5-1.6
Solubility in Water:0.01% @ 25C
Appearance and Odor:FLAKES, PALE YELLOW IN COLOR.
Percent Volatiles by Volume:<0.1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SODIUM HYDROXIDE, POTASSIUM HYDROXIDE AND OTHER HIGHLY ALKALINE
MATERIALS.
Stability Condition to Avoid:AVOID CONTACT WITH ALKALINE MATERIALS.
WILL DETONATE IF CONFINED AND EXPOSED TO EXTREME HEAT.
Hazardous Decomposition Products:NOX.
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN ON OPEN BURNING GROUND IN ACCORDANCE WITH
STATE AND LOCAL REGULATIONS. MAY ALSO BE BURNED IN AN INCINERATOR
APPROVED FOR EXPLOSIVES. DISPOSE OF IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULAT IONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:827 7097 EKTACOLOR RA DEVELOPER REPLENISHER/RA-4, W.S.
Kit Part:Y
CAGE:5K871
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 90-95%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM CARBONATE
CAS:584-08-7
RTECS #:TS7750000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHANOL, 2,2',2"-NITRILOTRI-; (TRIETHANOLAMINE)
CAS:102-71-6
RTECS #:KL9275000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:5 MG/M3
Ingred Name:DIETHYLHYDROXYLAMINE
CAS:3710-84-7
RTECS #:NC3500000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
Ingred
Name:4-(N-ETHYL-N-2-METHANESULFONYLAMINOETHYL)-2-METHYLPHENYLENEDIA
MINE
CAS:25646-71-3
RTECS #:PB0431000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): NOT GIVEN
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. EYE CONTACT MAY CAUSE TRANSIENT
IRRITATION. SKIN CONTACT MAY CAUSE ALLERGIC SKIN REACTION. HARMFUL
IF SWALLOWED. MAY CAUSE IRRITATION O F THE GASTROINTESTINAL TRACT
IF SWALLOWED.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION, ALLERGIC SKIN REACTION, GI
TRACT IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMMEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: DRINK 1-2 GLASSES OF WATER. NEVER GIVE ANYTHING BY MOUTH
TO AN UNCONSCIOUS PERSON. SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:NONFLAMMABLE. USE EXTINGUISHING MEDIA SUITABLE FOR
SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER IF ALLOWABLE WITH LARGE AMOUNTS
OF WATER. OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT
MATERIAL, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN
SURFACE TO REMOVE RESIDUA L CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PROLONGED OR REPEATED BREATHING
OF MIST OR VAPOR. AVOID CONTACT WITH EYES, SKIN AND CLOTHING. KEEP
CONTAINER CLOSED.
Other Precautions:THE ROUTINE USE OF A NONALKALINE (ACID) TYPE OF HAND
CLEANER AND REGULAR CLEANING OF WORKING SURFACES WILL HELP MINIMIZE
THE POSSIBILITY OF A SKIN REACTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE. THIS ENTRY FOR
WORKING SOLUTION.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.03
pH:10.8
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT YELLOW LIQUID, STRONG AMINE ODOR
Percent Volatiles by Volume:95-100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE WITH COMMON MATERIALS AND CONTAMINANTS WITH WHICH THE MATERIAL MAY
REASONABLY COME INTO CONTACT.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. MAY REQUIRE NEUTRALIZATION IF PH
< 2.0 OR PH > 12.5. DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE ANDLOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:3242-3302 HEATSET
Preparer's Name:DICK KARBO
CAGE:KMADD
CAGE:KMADD
============= Composition/Information on Ingredients =============
Ingred Name:COPPER COMPOUND
Fraction by Wt: 17%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED CONTACT W/SKIN/EYES CAN
CAUSE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMEDIATELY W/WATER. SKIN: WASH AFFECTED AREA
W/SOAP & WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>200F
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: WIPE UP & STORE WIPERS IN UNDERWRITERS
APPROVED CONTAINERS. LARGE: SCOOP MATERIAL INTO SEALABLE
CONTAINERS. WIPE UP REMAINDER & STORE WIPERS IN UNDERWRITERS
APPROVED CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS.
Other Precautions:AVOID CONTACT W/SKIN, EYES & CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS REQUIRED
Ventilation:LOCAL EXHAUST
Work Hygienic Practices:WASH AFTER USE. REMOVE/LAUNDER CONTAMINATED
CLOTHING BEFORE REUSE. DON'T CONSUME FOOD/BEVERAGE WHERE PRODUCT IS
USED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:470-610F
Evaporation Rate & Reference:SLOWER THAN WATER
Solubility in Water:INSOLUBLE
Appearance and Odor:OILY
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:METHYL ALCOHOL 14280, A412FB19
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:METHANOL; (METHYL ALCOHOL) (SARA 313) (CERCLA). LD50:
(ORAL, RAT) 5628 MG/KG.
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: >99%
OSHA PEL:200 PPM, S
ACGIH TLV:200 PPM; 250 STEL, S
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SUPDAT: BERYLLIUM DIHYDRIDE, CARBON TETRACHLORIDE + METALS,
CHLOROFORM + HEAT, CHLOROFORM + SODIUM HYDROXIDE, (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2: CYANURIC CHLORIDE, DIETHYL ZINC, NITRIC ACID &
POTASSIUM TERTBUTOXIDE. PLEASE REFER TO THE NFPA FIRE (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3: PROTECTION GUIDE FOR ALL SPECIFICS.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP: TO THOSE DESCRIBED FOR INGEST. CHRONIC:
PRLNGD/RPTD SKIN CONTACT MAY CAUSE DERM. CHRONIC INHAL (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: & INGEST MAY CAUSE EFTS SIMILAR TO THOSE OF ACUTE
INHAL & INGEST. TARGET ORGANS: KIDNEYS, CNS, LIVER, EYES.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: VOMIT BY GIVING ONE TEASPOON OF SYRUP OF
IPECAC. INHAL: GET MED AID IMMED. REMOVE FROM EXPOS TO (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: FRESH AIR IMMED. IF NOT BRTHG, GIVE ARTF RESP. IF
BRTHG IS DFCLT, GIVE OXYGEN. NOTE TO MD: EFTS MAY BE (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: DELAYED. ETHANOL MAY INHIBIT METABOLISM. ANTIDOTE:
NO SPECIFIC ANTIDOTE EXISTS.
RTECS #:9999999ZZ
Ingred Name:OTHER PRECS: CUT, WELD, BRAZE, SOLDER, DRILL, GRIND OR
EXPOSE EMTPY CNTNRS TO HEAT, SPARKS OR OPEN FLAMES.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: CAUSES MODERATE IRRIT. VAPS MAY
CAUSE IRRIT. MAY CAUSE PAINFUL SENSIT TO LIGHT. SKIN: MAY CAUSE
SKIN IRRIT. MAY BE ABSORBED THRU SKIN IN HARMFUL AMTS. INGEST: MAY
CAUSE IRRIT OF DIGEST TRACT. MAY CAUSE CNS DEPRESS CHARACTERIZED
BY EXCITEMENT, FOLLOWED BY HDCH, DIZZ, DROW & NAUS. ADVANCED STAGES
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: MAY CAUSE COLLAPSE, UNCON, COMA &
POSS DEATH DUE TO RESP FAILURE. MAY CAUSE KIDNEY FAILURE. INHAL:
MAY CAUSE RESP TRACT IRRIT. MAY CAUSE LIVER & KIDNEY DMG. MAY CAUSE
ADVERSE CNS EFTS INCLUD ING HDCH, CONVULSIONS & POSS DEATH.
MAYCAUSE VISUAL IMPAIRMENT & POSS PERM BLINDNESS. MAY CAUSE EFTS
SIMILAR (ING 5)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH EYES W/PLENTY OF WATER FOR AT LST 15 MIN,
OCCASNLY LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. DO NOT
ALLOW VICTIM TO RUB OR KEEP EYES CLOSED. SKIN: FLUSH SKIN W/PLENTY
OF SOAP & WATER FOR AT LST 15 MIN WHILE REMOVING CONTAMCLTHG &
SHOES. GET MED AID IF IRRIT DEVELOPS OR PERSISTS. INGEST: IF
CONSCIOUS & ALERT, GIVE 2-4 CUPFULS OF MILK OR WATER. GET MED AID
IMMED. INDUCE (ING 7)
===================== Fire Fighting Measures =====================
Flash Point:53.6F,12.0C
Lower Limits:6.0%
Upper Limits:31.0%
Extinguishing Media:FOR SMALL FIRES, USE DRY CHEMICAL, CARBON DIOXIDE,
WATER SPRAY OR ALCOHOL-RESIST FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO COOL FIRE EXPOSED CONTAINERS. WATER
MAY BE INEFFECTIVE.
Unusual Fire/Explosion Hazard:CNTNRS CAN BUILD UP PRESS IF EXPOSED TO
HEAT &/OR FIRE. VAPS CAN TRAVEL TO SOURCE OF IGNIT & FLASH BACK.
DURING FIRE, IRRITATING & HIGHLY TOX GASES MAY (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP UP WITH NONSPARKING TOOL, THEN PLACE
INTO SUITABLE CONTAINER FOR DISPOSAL. USE WATER SPRAY TO DISPERSE
GAS/VAPOR. REMOVE ALL SOURCES OF IGNITION. ABSORB SPILL USING
ABSORBENT, NON-COMBUSTIBLE MA TERIAL SUCH AS EARTH, SAND OR
VERMICULITE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM SOURCES OF IGNITION.
STORE IN A COOL, DRY, WELL-VENTILATED AREA AWAY FROM INCOMPATIBLE
SUBSTANCES.
Other Precautions:WASH THOROUGHLY AFTER HNDLG. REMOVE CONTAM CLTHG &
WASH BEFORE REUSE. USE W/ADEQ VENT. EMPTY CNTNRS RETAIN PROD
RESIDUE (LIQ &/OR VAP) & CAN BE DANGEROUS. DO NOT GET ON SKIN OR IN
EYES. DO NOT INGEST OR INHALE. DO NOT PRESSURIZE, (ING 10)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW OSHA RESPIRATOR REGULATIONS FOUND IN 29
CFR 1910.134. ALWAYS USE A NIOSH APPROVED RESPIRATOR WHEN
NECESSARY.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
AIRBORNE CONCENTRATIONS BELOW THE PERMISSIBLE EXPOSURE LIMITS.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN EXPOSURE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ: BE GENERATED BY THERMAL DECOMP OR COMBUSTS. FLAM LIQ. CAN
RELS VAPS THAT FORM EXPLO MIXS AT TEMPS ABOVE FLASH POINT. MATL TO
AVOID: SODIUM HYPOCHLORITE). ACTIVE METALS (SUCH AS POTASSIUM &
MAGNESIUM). SUBSTANCE IS ALSO INCOMPAT W/SPECIFIC CHEMS INCLUDING:
ACETYL BROMIDE, ALKYL ALUMINUM SALTS, (ING 2)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:148F,65C
Melt/Freeze Pt:M.P/F.P Text:-144F,-98C
Vapor Pres:96
Vapor Density:1.1
Spec Gravity:0.7910
Evaporation Rate & Reference:5.2 (ETHER =1)
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID; SLIGHT ALCOHOL-LIKE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDANTS (SUCH AS BARIUM PERCHLORATE, BROMINE, CHLORINE, HYDROGEN
PEROXIDE, LEAD PERCHLORATE, PERCHLORIC ACID, (SUPDAT)
Stability Condition to Avoid:STABLE AT ROOM TEMP IN CLSD CNTNRS UNDER
NORM STORAGE & HNDLG CNDTNS. AVOID HIGH TEMPS, INCOMPAT MATLS,
IGNIT SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
FORMALDEHYDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN A MANNER CONSISTENT WITH FEDERAL,
STATE AND LOCAL REGULATIONS. THIS MATERIAL IS BANNED FROM LAND
DISPOSAL ACCORDING TO RCRA.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:N,N'-DIMETHYL-1,6-HEXANEDIAMINE,98%D16110-1
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:N,N'-DIMETHYL-1,6-HEXANEDIAMINE, 98%
CAS:13093-04-4
Fraction by Wt: 98%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:MAY BE HARMFUL BY INHALATION OR
INGESTION. VAPOR OR MIST IS IRRITATING TO EYES, MUCOUS MEMBRANES
AND UPPER RESPIRATORY TRACT. CAUSES SKIN IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:IMMEDIATELY FLUSH W/COPIOUS AMTS OF WATER FOR AT LEAST
15 MINUTES. SKIN:IMMEDIATELY WASH W/SOAP & COPIOUS AMTS OF WATER.
WASH CONTAMINATED CLOTHING BEFORE REUSE. INHAL:REMOVE TO FRESH AIR.
SUPPOR T BREATHING (GIVE O*2/ARTF RESP), CALL MD. INGEST:CALL MD
IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:176F,80C
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL POWDER,
ALCOHOL OR POLYMER FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT TO PREVENT CONTACT WITH SKIN AND EYES.
COMBUSTIBLE LIQUID.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH/MSHA APPROVED SCBA, RUBBER BOOTS &
CLOSED CONTAINER & HOLD FOR WASTE DISPOSAL. VENTILATE AREA & WASH
SPILL SITE AFTER MAT ERIAL PICKUP IS COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE. KEEP TIGHTLY
CLOSED. KEEP AWAY FROM HEAT & OPEN FLAME. DO NOT GET IN EYES, ON
SKIN OR CLTHG. AVOID CONTACT & INHALATION.
Other Precautions:IRRITANT. HYGROSCOPIC.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER USE AND BEFORE
EATING, DRINKING, SMOKING OR USING SANITARY FACILITIES .
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:205F,96C
Spec Gravity:0.807
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF:CO, CO*2, NO*X.
==================== Disposal Considerations ====================
Waste Disposal Methods:COMBUSTIBLE MATERIAL MAY BE BURNED IN CHEMICAL
INCINERATOR EQUIPPED W/AFTERBURNER AND SCRUBBER. DISPOSE OF I/A/W
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LF-63526P
Preparer's Name:T R LOUER
CAGE:23027
CAGE:90227
CAGE:23027
============= Composition/Information on Ingredients =============
Ingred Name:VOLATILE ORGANIC CONTENT: 2.5 LBS/GAL
RTECS #:9999999VO
Ingred Name:SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC, HIGH FLASH
AROMATIC NAPHTHA, C8&10 AROMATIC HYDROCARBON *96-3*
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 9.13%
Ingred Name:BARIUM SULFATE, BARYTES *96-3*
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: 6.64%
OSHA PEL:10 MG/CUM
ACGIH TLV:10 MG/CUM
Ingred Name:BISPHENOL A DIGLYCIDYL ETHER RESIN, EPOXY RESIN, EPON 820,
ARALDITE 6004, AMINE ADDUCT, ARALDITE GY250 *96-3*
CAS:25068-38-6
RTECS #:KD4380000
Fraction by Wt: 30.75%
Ingred Name:DIACETONE ALCOHOL
CAS:123-42-2
RTECS #:SA9100000
Fraction by Wt: 6.87%
Other REC Limits:50 PPM
OSHA PEL:240 MG/CUM
ACGIH TLV:238 MG/CUM
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE * 96-3 *
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 4.22%
OSHA PEL:2 MG/CUM (RESP DUST)
ACGIH TLV:2 MG/CUM (RESP DUST)
Ingred Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
CARCINOGEN, IARC GROUP 3)*96-3*
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 36.66%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *96-3*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 1.34%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NOSE & THROAT IRRITATION.
REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE. SKIN: IRRITATION, DERMATITIS. EYES:
IRRITATION, BURNING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:GI DISTRESS, IRRITATION, EYE WATERING,
HEADACHE, NAUSEA, DIZZINESS, LOSS OF COORDINATION, DISCOMFORT,
BURNING.
======================= First Aid Measures =======================
First Aid:INGESTION: CALL A PHYSICIAN IMMEDIATELY & HAVE NAMES OF
INGREDIENTS AVAILABLE. INHALATION: REMOVE TO FRESH AIR. SKIN: WASH
THOROUGHLY W/SOAP & WATER. EYES: FLUSH W/WATER FOR 15 MINS. OBTAIN
MEDICAL AT TENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>100F
Extinguishing Media:WATER SPRAY, FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT W/SCBA. WATER
FROM FOG NOZZLES MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT
PRESSURE BUILD UP.
Unusual Fire/Explosion Hazard:WHEN HEATED ABOVE THE FLASH POINT, EMITS
FLAMMABLE VAPORS WHICH, WHEN MIXED W/AIR CAN BURN/EXPLODE. FINE
MISTS/SPRAYS MAY BE FLAMMABLE AT TEMP < FLASH POINT.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE IGNITION SOURCES.
PREVENT SKIN CONTACT & BREATHING OF VAPORS. WEAR A PROPERLY FITTED
VAPOR/PARTICULATE RESPIRATOR. CONFINE & REMOVE W/INERT ABSORBENT.
(SEE SUPP)
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM HEAT & OTHER IGNITION
SOURCES. CLOSE CONTAINERS AFTER EACH USE. GROUND CONTAINERS WHEN
POURING. WASH THOROUGHLY AFTER HANDLING.
Other Precautions:DON'T STORE >120F. DON'T SAND, FLAME CUT, BRAZE/WELD
DRY COATING W/O NIOSH/MSHA APPROVED RESPIRATOR/APPROPRIATE
VENTILATION. OBSERVE LABEL PRECAUTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A PROPERLY FITTED VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA. DON'T PERMIT ANYONE W/O
PROTECTION IN THE PAINTING AREA.
Ventilation:SUFFICIENT VENTILATION IN VOLUME & PATTERN TO KEEP
CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Other Protective Equipment:COVERALLS
Supplemental Safety and Health
%VOLATILE BY VOLUME: 28.3-64.2%. SPILLS CONT'D: IF MATERIAL HAS BEEN
ACTIVATED W/ISOCYANATE, WEAR A POSITIVE PRESSURE SUPPLIED AIR
RESPIRATOR.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:168-500F
Vapor Density:>1
Evaporation Rate & Reference:LESS THAN ETHER
Solubility in Water:MISCIBLE
Percent Volatiles by Volume:(SUPP)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS, FLAME, TEMP >120F.
Hazardous Decomposition Products:CO, CO2, SMOKE, OXIDES OF METALS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T ALLOW MATERIAL TO CONTAMINATE WATER
SYSTEMS. INCINERATE ABSORBED MATERIAL IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T INCINERATE IN CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:QUICK DRY ENAMEL SAFETY GREEN, 54-311
CAGE:47695
CAGE:47695
============= Composition/Information on Ingredients =============
Ingred Name:% VOLAT: 57.19 (WT)
RTECS #:9999999ZZ
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 2-5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:ALUMINUM SILICATE
CAS:1335-30-4
Fraction by Wt: 5-10%
Ingred Name:NAPHTHA, MEDIUM ALIPHATIC
CAS:64742-88-7
Fraction by Wt: 25-30%
Ingred Name:HYDROTREATED HEAVY NAPHTHA
CAS:64742-48-9
Fraction by Wt: 10-15%
Ingred Name:FILM FORMERS, RESINS, AND ADDITIVES
Fraction by Wt: 40-45%
Ingred Name:SUPP DATA:THERE IS NO SIGNIFICANT HAZ FOR MAN. EYE
WATER/HDCH/NAUS/DIZZ & LOSS OF COORD ARE INDICATIONS THAT SOLV(ING
7)
RTECS #:9999999ZZ
Ingred Name:ING 6:LEVELS ARE TOO HIGH. RED/ITCH/BURN SENSATION & VISUAL
DISTURB MAY INDICATE EXCESS EYE CONT. DRY/ITCH/CRACK (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:BURN/RED & SWELL ARE CONDITIONS ASSOCIATED WITH
EXCESSIVE SKIN CONTACT.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:IN EXCESS OF FEW INCHES.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:TYPE OF AIRBORNE CONTAM AGAINST WHICH RESPIRATORY
IS EFFECTIVE & HOW IT IS TO BE PROPERLY FITTED.
RTECS #:9999999ZZ
Ingred Name:VENT:EXPO LIM, LEL IN INGRED BELOW STATED LIM, & TO REMOVE
DECOMP PROD DURING WELD/FLAME CUT ON SURF COATED W/ (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:PRODUCT.
RTECS #:9999999ZZ
Ingred Name:OTHER PROT EQUIP: CLEAN OR DISCARD CONTAMINATED CLOTHING
AND SHOES.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INGEST:HARMFUL/FATAL IF
SWALLOWED. EYE:CAUSES IRRIT. SKIN:MAY CAUSE MOD IRRIT.
INHAL:VAP/SPRAY MIST MAY BE HARMFUL IF INHALED. VAP IRRITATES
EYES/NOSE/THROAT. RPTD EXPOS TO HIGH VAP CONC MAY CAU SE IRRIT OF
RESP SYS & PERM BRAIN & NERV SYS DAM. INTENTIONAL MISUSE BY DELIB
CONC & INHALING CONTENTS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:CAN BE HARMFUL/FATAL. CHRONIC:AVOID
LONG TERM & RPTD CONT. PROD CNTNS TITANIUM DIOXIDE. ANIMALS
INHALING MASSIVE QTY OF TITANIUM DIOXIDE DUST IN LONG-TERM STUDY
DEVELOPED LUNG TUMORS. STUDIES W/HUMANS INVOLVED IN MFR OF PIGMENT
INDICATE NO INCR RISK OF CANCER FROM EXPOS. POTNTL FOR INHAL OF
TITANIUM(SUPP DATA)
======================= First Aid Measures =======================
First Aid:INGEST:DO NOT INDUCE VOMIT. EYE:FLUSH IMMED WITH PLENTY OF
WATER FOR AT LEAST 15 MIN. SKIN: REMOVE PROMPTLY BY WIPING,
FOLLOWED BY WATERLESS HAND CLEANER AND SOAP AND WATER. INHAL:REMOVE
TO FRESH AIR. APPLY ARTF RESP & OTHER SUPPORTIVE MEASURES AS REQ.
IF ANY OF FOLLOW OCCUR DURING/FOLLOW USE OF PROD, CONT POIS CTRL
CTR, EMER ROOM/PHYS IMMED; HAVE MATL SFTY DATA SHEET INFO
AVAILABLE.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:112F,44C
Lower Limits:0.9%
Extinguishing Media:USE NATL FIRE PROT ASSOC (NFPA) CLASS B EXTING
(CO*2/DRY CHEM/UNIVERSAL AQUEOUS FILM FORM FOAM) DESIGNED TO (SUPP
DATA)
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP. H*2O
SPRAY MAY BE INEFT. H*2O SPRAY MAY BE USED TO COOL CLSD CONTR TO
PVNT PRESS BUILDUP & POSS (SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP CONTR TIGHTLY CLSD. ISOLATE FROM
HEAT/ELEC EQUIP/SPARKS/OPEN FLAMES. CLSD CONTR MAY EXPLODE WHEN
EXPOS TO EXTREME HEAT. DO NOT APPLY TO HOT (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:PROVIDE MAX VENT. ONLY PERS EQUIPPED W/PROPER
RESP & SKIN & EYE PROT SHOULD BE PERMITTED IN AREA. REMOVE ALL
SOURCES OF IGNIT. TAKE UP SPILLED MATLS/SAWDUST/VERMICULITE/OTHER
ABSORB MATL & PLACE INTO CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. STORE LG QTY
IN BUILDINGS DESIGNED & PROTECTED FOR STORAGE OF NFPA CLASS II
COMBUSTIBLE LIQUIDS.
Other Precautions:IF MATL IS PART OF MULTIPLE COMPONENT COAT SYSTEM,
READ MATL SFTY DATA SHEET(S) FOR OTHER COMPONENT/COMPONENTS BEFORE
BLEND AS RSLTG MIX MAY HAVE HAZ OF ALL OF ITS PARTS. CONTR SHOULD
BE GROUND WHEN P OUR. AVOID FREE FALL OF LIQ (ING 9)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:OVEREXP TO VAP MAY BE PVNTD BY ENSURING VENT
CTRLS, VAP EXHAUST/FRESH AIR ENTRY. NIOSH/MSHA APPRVD (TC-23C-)
PAINT SPRAY/AIR SUPPLIED (TC-19C) RESP MAY ALSO REDUCE EXPOS. READ
RESP MFR INSTRUCTIONS & LITEARTURE CAREFULLY TO DETERM (ING 10)
Ventilation:PROVIDE GEN DILUTION/LOC EXHAUST VENT IN VOL & PATTERN TO
KEEP CONC OF INGRED LISTED BELOW LOWEST SUGGESTED (ING 11)
Other Protective Equipment:IMPERMEABLE APRONS CONSTRUCTED OF: POLYVINYL
ALCOHOL, NEOPRENE RUBBER, NITRILE RUBBERBUTYL RUBBER/LATEX RUBBER.
(ING 13)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXTING MEDIA:EXTING NFPA CLASS II COMBUST LIQ FIRES. EXPLO HAZ:SURF.
TOX GASES MAY FORM WHEN PROD IS CONTACTED BY FLAME/HOT SURF. FIRE
FIGHT PROC:AUTOIGNIT/EXPLO WHEN EXPOS TO EXTREME HEAT. IF H*2O IS
USED, FOG NOZZLES ARE PREF. EFTS OF OVEREXP:DIOXIDE DUSTS FROM COAT
IS VERY LIM. SINCE OVEREXP IS NOT EXPECTED, (ING 6)
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:277F,136C
Vapor Pres:1.7
Vapor Density:HVR/AIR
Spec Gravity:1.00
Evaporation Rate & Reference:17(BUAC=100)
Solubility in Water:0.0%
Appearance and Odor:VISCOUS LIQUID W/AN ODOR CHARACTERISTIC OF SOLV IN
INGREDIENTS
Percent Volatiles by Volume:ING 14
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG ALKALIES, STRONG MINERAL ACIDS, OR STRONG
OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY PRODUCE HAZ DECOMP PROD WHEN
HEATED. WELD/BRAZ/FLAME-CUT ON SURF COATED WITH PROD MAY PRODUCE
FUMES INCL CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MATERIAL MUST BE DISPOSED OF IN ACCORDANCE
WITH FEDERAL, STATE, PROVINCIAL, AND LOCAL ENVIRONMENTAL CONTROL
REGULATIONS. EMPTY CONTAINERS SHOULD BE RECYCLED OR DISPOSED OF
THROUGH AN APPROVED WA STE MANAGEMENT FACILITY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:S7727 YELLOW LEAD FREE ISLE MARKING
CAGE:EO523
CAGE:EO523
CAGE:39934
============= Composition/Information on Ingredients =============
Ingred Name:PROPYLENE GLYCOL N-BUTYL ETHER
Fraction by Wt: 3.44%
Ingred Name:2-((2-ETHYLHEXYL)OXY), ETHYLENE GLYCOL, 2-ETHYL HEXYL ETHER
*96-4*
CAS:1559-35-9
RTECS #:KK9625000
Fraction by Wt: 0.57%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: CAN CAUSE IRRITATION OF
THE NOSE, THROAT & LUNGS. EYES/SKIN: SLIGHT IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:HEADACHE, NAUSEA, IRRITATION.
Medical Cond Aggravated by Exposure:PRE-EXISTING LUNG DISEASE.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH W/A LARGE AMOUNT
OF WATER FOR 15 MINS. SKIN: WASH AREAS THOROUGHLY W/SOAP & WATER.
INGESTION: GIVE 2 GLASSES OF WATER TO DRINK. NEVER GIVE ANYTHING TO
UNCO NSCIOUS PERSON. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:216F
Lower Limits:1.1
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR SCBA (PRESSURE DEMAND MSHA/NIOSH
APPROVED/EQUIVALENT) & FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:MATERIAL CAN SPLATTER >212F. POLYMER FILM
CAN BURN.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN W/INERT MATERIALS. TRANSFER LIQUIDS &
SOLID DIKING MATERIAL TO SEPERATE SUITABLE CONTAINERS FOR
RECOVERY/DISPOSAL. KEEP RUNOFF OUT OF MUNICIPAL SEWERS & OPEN
BODIES OF WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING, MATERIAL MAY
COAGULATE. STORE AT <40F & >120F. USE W/ADEQUATE VENTILATION. KEEP
LID TIGHTLY CLOSED AFTER EACH USE.
Other Precautions:AVOID SKIN & EYE CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AN APPROPRIATE NIOSH APPROVED RESPIRATOR TO
REMOVE ORGANIC VAPORS & TO REMOVE THE AIRBORNE PARTICLES.
Ventilation:GOOD GENERAL ROOM/LOCAL EXHAUST: RECOMMENDED AT LEAST 10
AIR CHANGES PER HOUR.
Other Protective Equipment:EYE BATH & WASHING FACILITIES.
Work Hygienic Practices:MINIMIZE SKIN CONTACT & MINIMIZING INHALATION
OF VAPORS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212-644F
Vapor Density:<1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:66.32
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & STRONG OXIDIZERS.
Stability Condition to Avoid:HEAT, FLAMES, FREEZING.
Hazardous Decomposition Products:COMBUSTION: CO2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:OUTBOUND RUBBER OR SHELLAC BONDED ADHESIVE PRODUCTS
CAGE:44197
CAGE:44197
============= Composition/Information on Ingredients =============
Ingred Name:ZIRCONIUM OXIDE
CAS:1314-23-4
RTECS #:ZH8800000
Fraction by Wt: 30-50%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ALUMINUM OXIDE (2:3); (ALUMINUM OXIDE) (SARA 313)
CAS:1344-28-1
RTECS #:BD1200000
Fraction by Wt: 40-90%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:FIBERGLASS (FIBROUS GLASS)
CAS:65997-17-3
Fraction by Wt: .003-10%
OSHA PEL:5 MG/M3 RESP DUST
ACGIH TLV:10 MG/M3 (<7MICRONS)
Ingred Name:SILICON CARBIDE
CAS:409-21-2
RTECS #:VW0450000
Fraction by Wt: 80-90%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 0.001-1%
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 5-11%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:PHTHALIC ACID, DIBUTYL ESTER; (DIBUTYL PHTHALATE) (SARA
313) (CERCLA)
CAS:84-74-2
RTECS #:TI0875000
Fraction by Wt: 0.010-1%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:DISULFIDE, BIS(DIMETHYLTHIOCARBAMOYL);
(BIS(DIMETHYLTHIOCARBMYL)DISULF) (SARA 313) (CERCLA)
CAS:137-26-8
RTECS #:JO1400000
Fraction by Wt: 0.010-1%
OSHA PEL:5 MG/M3
ACGIH TLV:1 MG/M3
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:SILICA, AMORPHOUS, PRECIPITATED AND GEL; (AMORPHOUS SILICA
GEL)
CAS:112926-00-8
RTECS #:VV7315000
Fraction by Wt: 0.010-2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:FLUORIDES
Fraction by Wt: 2-10%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: DUST MAY BE
SLIGHTLY IRRITATING TO EYES AND RESPIRATORY TRACT AT HIGH
CONCENTRATIONS. EYES: DUST MAY IRRITATE EYES. SKIN: SOME MAY
EXPERIENCE SKIN IRRITATION FROM DUST. INGESTION: N O KNOWN ADVERSE
EFFECTS, BUT INGESTION NOT RECOMMENDED. CHRONIC: MAY AFFECT
BREATHING CAPACITY.
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUART: IARC
MONOGRAPHS, SUPPLEMENT, VOL 7, PG 341, 1987: GROUP 2A. NTP 7TH
ANNUAL REPORT ON CARCINOGENS, 1994: ANTICIPATED TO BE CARCINOGEN.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING HAS STOPPED,
GIVE ARTIFICIAL RESPIRATION. GET MEDICAL ATTENTION IMMEDIATELY.
SKIN: WASH AFFECTED AREAS WITH SOAP AND WATER. OBTAIN MEDICAL
ASSISTANCE. EYE S: WASH WITH LARGE AMOUNTS OF WATER FORAT LEAST 15
MINUTES. OBTAIN FIRST AID AND MEDICAL ASSISTANCE, IF NEEDED.
INGESTION: CALL POISON CONTROL CENTER, HOSPITAL EMERGENCY ROOM OR
MD IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:FOLLOW NORMAL CLEAN UP PROCEDURES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:ALWAYS HANDLE & STORE WHEELS IN
CAREFUL MANNER, VISUALLY INSPECT ALL WHEELS BEFORE MOUNTING, CHECK
MOUNTING FLANGES FOR EQUAL & CORRECT DIAMETER.
Other Precautions:ALWAYS CHECK MACHINE SPEED AGAINST ESTABLISHED MAX
SAFE OPERATING SPEED MARKED ON WHEEL, USE MOUNTING BLOTTERS, BE
SURE WORK REST IS PROPERLY ADJUSTED, USE SFTY GUARD COVERING AT
LEAST ONE-HALF OF GRI NDING WHEEL, ALLOW NEWLY MOUNTED WHEELS TO
RUN AT OPERATING SPEED, W/GUARD IN PLACE, FOR AT LEAST 1 MIN
BEFORE (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR REQUIRED WHEN
AIRBORNE CONTAMINANT LEVELS EXCEED THE TLV.
Ventilation:HANDLE WITH ADEQUATE VENTILATION. SEE OSHA 29 CFR 1910.94
(VENTILATION) AND 29 CFR 1910.1000 (AIR CONTAMINANTS).
Other Protective Equipment:USE OF THIS PRODUCT MAY CREATE ELEVATED
SOUND LEVELS. HEARING PROTECTION SHOULD BE WORN WHERE REQUIRED.
(SEE OSHA 29 CFR 1910.134 AND OTHER APPLICABLE REGULATIONS.)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
OTHER PREC: GRINDING, TURN OFF COOLANT BEFORE STOPPING WHEEL TO AVOID
CREATING AN OUT-OF-BALANCE WHEEL.
================== Physical/Chemical Properties ==================
Appearance and Odor:SOLID, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:IN USE, DUST & DECOMP ODORS ARE
GENERATED. IN MOST CASES, MATL REMOVED FROM WORKPLACE WILL BE
SIGNIFICANTLY GREATER THAN GRINDING WHEEL COMPONENTS. COOLANTS MAY
PRODUCE OTHER DECOMP PRODS.
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW LANDFILL METHODS CONSISTENT WITH
APPLICABLE FEDERAL, STATE, AND LOCAL LAWS. PRODUCTS LISTED WITH
FLUORIDES MAY HAVE SLIGHTLY SOLUBLE FLUORIDE SWARF.
| 1 | gloves_mandatory |
=======================================================
Product ID: 6707 CADMIUM RED MED SPEEDBALL ACRYLIC ARTISTS COLORS
Cage: 08287
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 08287
=======================================================
Contractor Summary
=======================================================
Cage: 08287
=======================================================
Ingredients
=======================================================
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES/SKIN: CONTACT MAY CAUSE IRRITATION.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: IRRITATION
First Aid: EYES/SKIN: FLUSH W/WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: FLOOR MAY BE SLIPPERY; USE CARE TO AVOID FALLING.
TRANSFER TO CONTAINERS FOR RECOVERY/DISPOSAL. KEEP OUT OF MUNICIPAL SEWERS
& OPEN BODIES OF WATER.
Waste Disposal Methods: INCINERATE AT A PERMITTED FACILITY/DISPOSE OF IN
ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
Handling And Storage Precautions: KEEP FROM FREEZING; PRODUCT MAY COAGULATE.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Fire Fighting Procedures: WEAR SELF CONTAINED BREATHING APPARATUS
PRESSURE-DEMAND MSHA/NIOSH APPROVED & FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard: MATERIAL CAN SPATTER ABOVE 212F. FILM CAN BURN.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE REQUIRED W/ADEQUATE VENTILATION & NORMAL
OPERATING CONDITIONS.
Ventilation: ADEQUATE
Work Hygienic Practices: USE PROTECTIVE CREAM WHERE EXCESSIVE SKIN CONTACT IS
LIKELY.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 212F
M.P/F.P Text: <32F
Decomp Text: 350F
Vapor Pres: 17
Vapor Density: <1
Spec Gravity: 1.1-1
VOC Pounds/Gallon: .68
Evaporation Rate & Reference: LESS THAN BUTYL ACETATE
Solubility in Water: DILUTABLE
Appearance and Odor: THICK PASTE/ACRYLIC EMULSION ODOR
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: FREEZING
Hazardous Decomposition Products: OXIDES OF CARBON & NITROGEN
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: VOLATILE ORGANIC CONTENT: 0.48-0.68 LBS/GAL
=======================================================
HAZCOM Label
=======================================================
Product ID: 6707 CADMIUM RED MED SPEEDBALL ACRYLIC ARTISTS COLORS
Cage: 08287
Company Name: HUNT MANUFACTURING CO.
Street: SPEEDBALL RD
Zipcode: 28677
Label Required IND: Y
Date Of Label Review: 10/12/1999
Status Code: A
Origination Code: G
Hazard And Precautions: EYES/SKIN: CONTACT MAY CAUSE IRRITATION.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:3068 RAPIDOOZE PEN CLEANER
CAGE:JO336
CAGE:JO336
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM HYDROXIDE
CAS:1310-58-3
RTECS #:TT2100000
< Wt:1.
ACGIH STEL:C2 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TRIETHANOLAMINE
CAS:102-71-6
RTECS #:KL9275000
Minumum % Wt:5.
Maxumum % Wt:10.
ACGIH TLV:5 MG/M3
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Minumum % Wt:85.
Maxumum % Wt:90.
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE IRRITATION TO SKIN, EYES AND
MUCOUS MEMBRANES
Effects of Overexposure:INGESTION MAY CAUSE GASTRIC DISTURBANCES.
======================= First Aid Measures =======================
First Aid:FLUSH EYES AND SKIN WITH LARGE AMOUNTS OF WATER. IF INGESTED
DRINK 1 OR 2 GLASSES OF WATER, DILUTE VINEGAR (20%) OR LEMON JUICE
MAY BE GIVEN. CONSULT PHYSICIAN OR POISON CONTRROL CENTER.
===================== Fire Fighting Measures =====================
Extinguishing Media:THIS FLUID WILL NOR BURN OR SUPPORT COMBUSTION
Fire Fighting Procedures:HIGH TEMPATURES WILL EVAPORATE THE WATER AND
THE REMAINING RESIDUE WILL BURN. WATER IS AN ADEQUATE EXTINGUISHING
MEDIA.
================== Accidental Release Measures ==================
Spill Release Procedures:IT IS NOT A REGULATED PRODUCT. SPILLS SHOULD
BE CONTAINED NEUTRALIZED WITH A SUITABLE ACID AND PLACED IN
CONTAINERS FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:EXTREME HEAT OR COLD MAY CAUSE
STRATIFICATION WHICH DISAPPEARS AT ROOM TEMPATURE.
============= Exposure Controls/Personal Protection =============
Ventilation:MECHANICAL
Other Protective Equipment:USE PROTECTIVE CREAM WHERE WXCESSIVE SKIN
CONTACT IS LIKELY.
Work Hygienic Practices:USE IN ACCORDANCE WITH MANUFACTURE'S
INSTRUCTIONS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:=212.C, 413.6F
B.P. Text:212 C
Melt/Freeze Pt:=-3.3C, 26.F
M.P/F.P Text:26-29 F
Vapor Pres:LIKE WATER
Vapor Density:LIKE WATER
Spec Gravity:1.024
pH:11.9
Evaporation Rate & Reference:LIKE WATER
Solubility in Water:MISCIBLE
Appearance and Odor:WHITE TURBID LIQUID MILD SOAP ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE, BURY OR RUN INTO SEWER IN ACCORDANCE
WITH ALL LEGAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TRI-MULSI R-357
CAGE:3Y338
CAGE:3V338
CAGE:3Y338
============= Composition/Information on Ingredients =============
Ingred Name:HEAVY AROMATIC NAPHTHA _
RTECS #:DE0330000
Fraction by Wt: >80%
Ingred Name:2-BUTOXYETHANOL
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: <10%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
===================== Hazards Identification =====================
Effects of Overexposure:NAUSEA & DIZZINESS. DEFATTING OF SKIN.
BURNING/IRRITATING OF EYES. GASTROINTESTINAL IRRITATION.
======================= First Aid Measures =======================
First Aid:SKIN: WASH WITH SOAP AND WATER. EYES: FLUSH WITH CLEAR WATER
15 MINUTES. INHALATION: REMOVE TO FRESH AIR. INGESTION: DON'T
INDUCE VOMITING. GET PROMPT MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:143F TCC
Extinguishing Media:DRY FOAM, CO2 OR OTHER SMOTHERING MEDIA.
Fire Fighting Procedures:POS. PRESS SCBA. WATER COOL CONTAINERS.
Unusual Fire/Explosion Hazard:INTENSE HEAT MAY RUPTURE CONTAINERS DUE
TO PRESSURE BUILDUP.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL/ABSORB W/GRANULAR CLAY OR
SAWDUST, CONFINE ABSORBANT MATTER TO A METALONTAINER W/TIGHT
SEAL/DISPOSE OF IN AN AUTHORIZED LANDFILL SITE. WASH AFCTED AREA
W/DETERGENT/RINSE W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN. DON'T
USE OR STORE PRODUCT NEAR HEAT OR OPEN FLAME. OPEN BUNG SWLY TO
ALLOW VAPOR TO ESCAPE.
Other Precautions:STORE IN ORIGINAL SHIPPING CONTAINER AND KEEP
CONTAINER WELL SEALED TO PREVENT EVAPORATION LOSS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Ventilation:LOCAL EXHAUST/MECHANICAL: ADEQUATE
Other Protective Equipment:NONE REQUIRED
Supplemental Safety and Health
MSDS DATED: MAY 87.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:330F
Vapor Density:1
Spec Gravity:0.895
Evaporation Rate & Reference:(TOLUENE = 1) 0.10
Solubility in Water:EMULSIFIABL
Appearance and Odor:AMBER, CLEAR, NON-VISC. LIQUID W/PETROLEUM ODOR
Percent Volatiles by Volume:87%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:DON'T MIX EXCEPT W/WATER OR OIL;
HEAT/FLAMES
Hazardous Decomposition Products:NOX, COX, UNIDENTIFIED ORGANIC
COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:SPENT MATERIAL MAY BE DISPOSED OF AT A SANITARY
LANDFILL SITE. EMPTY CONTAINER MAY BE OFFERED FOR RECYCLING OR SENT
TO A LANDFILL SITE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BLACK TONER
CAGE:PITNE
CAGE:PITNE
CAGE:PITTN
============= Composition/Information on Ingredients =============
Ingred Name:IRON OXIDE, MAGNETITE *95-4*
CAS:1317-61-9
Fraction by Wt: 35%
Ingred Name:SILICON DIOXIDE, CELITE 322, AMORPHOUS SILICA GEL*95-4*
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 1%
OSHA PEL:80 MG/CUM
ACGIH TLV:0.2 MG/CUM
Ingred Name:2-PROPENOIC ACID, 2-METHYL-POLYMER WITH BUTYL-2-PROPENOATE
AND ETHNYLBENZENE *95-4*
CAS:25036-16-2
Fraction by Wt: 59%
Ingred Name:PROPENE POLYMERS, POLYPROPYLENE, POLYOLEFINE
CAS:9003-07-4
RTECS #:UD1842000
Fraction by Wt: 2%
Ingred Name:SALT POLYMER
CAS:133350-42-2
Fraction by Wt: 2%
Ingred Name:TITANIUM, TRIS(ISOOCTADECANOATO-O)(2-PROPANOLATO)
CAS:61417-49-0
Fraction by Wt: 1%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MINIMAL RESPIRATORY TRACT
IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH THOROUGHLY W/COLD WATER. SKIN: WASH W/SOAP & COLD
WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION: DILUTE STOMACH
CONTENTS W/SEVERAL GLASSES OF COLD WATER. OBTAIN MEDICAL ATTENTION
IN AL L CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, FOAM/DRY CHEMICAL, CO2
Unusual Fire/Explosion Hazard:NONE UNDER NORMAL STORAGE & USE
CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP W/VACUUM CLEANER.
======================Handling and Storage ======================
Handling and Storage Precautions:CLOSE CAP TIGHTLY & STORE IN A COOL,
DRY & DARK PLACE.
Other Precautions:AVOID COMBUSTION. AVOID INHALATION, INGESTION,
SKIN/EYE CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL USE.
Ventilation:NONE REQUIRED UNDER NORMAL USE.
WHEN HANDLING BULK AMOUNTS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:312.4F
Spec Gravity:1.4
Solubility in Water:INSOLUBLE
Appearance and Odor:FINE BLACK POWDER, PRACTICALLY ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE IN NORMAL HANDLING & USE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:GASOLINE, UNLEADED (ALL GRADES)
CAGE:JO755
CAGE:3R470
CAGE:JO755
============= Composition/Information on Ingredients =============
Ingred Name:GASOLINE - PRODUCT MIXTURE CONTAINING THE FOLLOWING
HAZARDOUS INGREDIENTS.
CAS:8006-61-9
RTECS #:LX3300000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:300 PPM/500 STEL
ACGIH TLV:300 PPM/500STEL;9293
Ingred Name:BENZENE (SARA III)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: 0.1-4.9%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1PPM/5STEL;1910.1028
ACGIH TLV:10 PPM; A2; 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:ETHYL BENZENE (SARA III)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM/125 STEL
ACGIH TLV:100 PPM/125STEL 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:CUMENE (SARA III)
CAS:98-82-8
RTECS #:GR8575000
Fraction by Wt: 1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:1,2,4-TRIMETHYLBENZENE (SARA III)
CAS:95-63-6
RTECS #:DC3325000
Fraction by Wt: <15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:25 PPM
ACGIH TLV:25 PPM; 9293
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 12%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS >5G/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INHALATION: MODERATE RISK OF VAPOR
INTOXICATION. MAJOR RISK IS ENCLOSED SPACES WITH POOR VENTILATION.
SKIN: DEFATTING WITH DRYING AND CRACKING CAN LEAD TO DERMATITIS AND
SECONDARY INFECTION. EYE: IRRI TANT. INGESTION: BURNING OF MOUTH
AND UPPER GI TRACT, VOMITING AND DIARRHEA. PROLONGED OR REPEATED
CONTACT: DERMATITIS.
Explanation of Carcinogenicity:CONTAINS B[71-43-2] WHICH IS
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:INHALATION MAY CAUSE EUPHORIA, LUNG IRRITATION
AND EDEMA, HEADACHE, DIZZINESS, DROWSINESS, CONVULSIONS, COMA,
CYANOSIS, GENERALIZED DEPRESSION. INGESTION MAY CAUSE GENERAL
DEPRESSION, SEDATION, RESPIR ATORY DEPRESSION, COMA.
Medical Cond Aggravated by Exposure:MAY AGGRAVATE PRE-EXISTING
DERMATITIS, RESPIRATORY ILLNESS, OR OTHER CONDITIONS WHICH HAVE THE
SAME SYMPTOMS OR EFFECTS AS STATED ABOVE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH RUNNING WATER FOR 15 MINUTES WHILE HOLDING
EYELIDS OPEN. SKIN: REMOVE CONTAMINATED CLOTHING. WASH SKIN WITH
SOAP AND WATER. INHALATION: REMOVE TO FRESH AIR. FOR RESPIRATORY
DISTRESS, GIVE AIR, OXYGEN, OR CPR IF NECESSARY. INGESTION: DO NOT
INDUCE VOMITING. KEEP HEAD BELOW HIPS IF VOMITING OCCURS TO PREVENT
ASPIRATION INTO LUNGS. GET MEDICAL ATTENTION IF REQUIRED IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>-50F,>-46C
Lower Limits:<1
Upper Limits:8
Extinguishing Media:USE CARBON DIOXIDE, FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE ON FLAMES, BUT SHOULD
BE USED TO KEEP FIRE-EXPOSED CONTAINERS COOL. WATER SPRAY MAY BE
USED TO FLUSH SPILL AWAY FROM AREAS OF IGINTION.
Unusual Fire/Explosion Hazard:HIGHLY VOLATILE MATERIAL. FLOWING
GASOLINE CAN BE IGNITED BY SELF-GENERATED STATIC ELECTRICITY.
VAPORS MAY TRAVEL ALONG THE GROUND TO A REMOTE IGNITION SOURCE.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: TAKE UP WITH NON COMBUSTIBLE ABSORBENT
SUCH AS FULLERS EARTH OR SAND. PLACE INTO CONTAINERS FOR LATER
DISPOSAL. LARGE: CONTAIN SPILL IN EARTHEN DIKES FOR LATER RECOVERY.
CONTROL IGNITION SOURCE S AROUND SPILL AREA. REPORT SPILLS AS
REQUIRED.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID STATIC IGNITION HAZARD WHEN
TRANSFERRING MATERIAL. KEEP CONTAINERS CLOSED AND AWAY FROM HEAT &
IGNITION SOURCES! DO NOT USE AS CLEANING AGENT.
Other Precautions:EMPTY CONTAINERS RETAIN SOME LIQUID/VAPOR RESIDUES;
HAZARD PRECAUTIONS MUST BE OBSERVED WHEN HANDLING EMPTIES. KEEP OUT
OF REACH OF CHILDREN! DO NOT USE ANY HYDROCARBON FUEL IN SPACES
WITHOUT ADEQUATE VENTILATION. USE ONLY AS A FUEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH/MSHA APPROVED ORGANIC VAPOR RESPIRATOR,
SUPPLIED AIR, OR SELF-CONTAINED BREATHING APPARATUS (SCBA) MUST BE
USED WHEN VAPOR CONCENTRATIONS EXCEED THE OCCUPATIONAL EXPOSURE
LIMITS.
Ventilation:USE ADEQUATE VENTILATION TO KEEP VAPOR CONCENTRATIONS OF
THIS MATERIAL BELOW THE OCCUPATIONAL EXPOSURE LIMITS.
Other Protective Equipment:OIL IMPERVIOUS INDUSTRIAL WORK CLOTHING TO
MINIMIZE SKIN CONTACT. EYE BATH AND SAFETY SHOWER RECOMMENDED.
Work Hygienic Practices:USE GOOD PERSONAL HYGIENE. USE WATERLESS HAND
CLEANER TO WASH EXPOSED SKIN. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
THE VARIABLE COMPOSITION MAKES IT IMPOSSIBLE TO SET A SPECIFIC EXPOSURE
LIMIT FOR ALL COMPOSITIONS OF THIS MATERIAL. SPECIFIC EXPOSURE
LIMITS FOR POTENTIAL COMPONENTS SUCH AS BENZENE SHOULD BE APPLIED
BASED ON AIR MONITORING TO ASSURE EMPLOYEES ARE NOT EXPOSED TO
EXCESSIVE VAPOR LEVELS OF COMPONENTS.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:>85F,>29C
Vapor Pres:275-437
Vapor Density:>1
Spec Gravity:0.70-0.77
Solubility in Water:SLIGHT
Appearance and Odor:RED-DYED, PINK OR COLORLESS LIQUID; GASOLINE ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:BURNING OR EXCESSIVE HEATING MAY
PRODUCE CARBON MONOXIDE AND OTHER HARMFUL GASES/VAPORS.
==================== Disposal Considerations ====================
Waste Disposal Methods:IT IS THE RESPONSIBILITY OF THE USER TO
DETERMINE IF THE MATERIAL IS A HAZARDOUS WASTE AT THE TIME OF
DISPOSAL. CHECK BEFORE DISPOSING TO BE SURE YOU ARE IN COMPLIANCE
WITH ALL APPLICABLE LAWS AND REG ULATIONS. CHEMTREC/RCRA EMER.
NO.:800-424-9346
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CONATHANE TU-970 PART A
Kit Part:Y
CAGE:DO146
CAGE:DO146
INC.
CAGE:16245
============= Composition/Information on Ingredients =============
Ingred Name:ING 10:CHRONIC OVEREXP TO ISOCYANATE HAS ALSO BEEN RPTD TO
CAUSE LUNG DMG (INCL DECR IN LUNG FUNC) WHICH MAY BE (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:PERM. SENSITIZATION CAN EITHER BE TEMPORARY OR
PERMANENT.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:FOR SEV EXPOS, GET UNDER SFTY SHOWER AFTER
REMOVING CLTHG. SEEK MED ATTN IF IRRIT/ALLERGIC DERM (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:SYMPS DEVELOP/IF GROSS EXPOS OCCURS. INHAL:MOVE TO
AREA FREE FROM FURTHER RISK OF EXPOS. ADMIN OXYG/ARTF(ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:RESP AS NEEDED. OBTAIN MED ATTN. ASTHMATIC-TYPE
SYMPS MAY DEVELOP & MAY BE IMMED/DELAYED UP TO SEVERAL (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:HRS. TREATMENT IS ESSNTLY SYMPTOMATIC. CONSULT PHYS.
INGEST:DO NOT INDUCE VOMIT. GIVE 1-2 CUPS OF MILK/ (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:WATER TO DRINK. DO NOT GIVE ANYTHING BY MOUTH TO
UNCON/CONVL PERSON. CONSULT PHYS. REC TO PHYS:FOR INFO (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:CONTACT NEHC .
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:OTHER ABSORB MATL; POUR LIQ DECONTAM OVER
SPILLAGE--ALLOW TO REACT @ LST 10 MINS, COLLECT MATL IN (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19:OPEN CNTNRS-ADD FURTHER AMTS OF DECONTAM SOLN.
REMOVE CNTNRS TO SAFE PLACE-COVER LOOSELY. WASH DOWN AREA (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20:W/DECONTAM & FLUSH AREA W/WATER. DECONTAM
SOLNS:AMMONIUM HYDROXIDE (0-10%), DETERGENT (2-5%) & BALANCE (ING
22)
RTECS #:9999999ZZ
Ingred Name:ING 21:WATER/SOLN OF UNION CARBIDE'S TERITOL TMN-10 (20%)
AND WATER (80%).
RTECS #:9999999ZZ
Ingred Name:VENT:LOC EXHAUST:REC. EXHAUST AIR MAY NEED TO BE CLEANED BY
SCRUBBERS/FILTERS TO REDUCE ENVIR CONTAMINATION.
RTECS #:9999999ZZ
Ingred Name:EYE PROT:& FULL FACESHIELD .
RTECS #:9999999ZZ
Ingred Name:ISOCYANIC ACID, METHYLENEDI-4,1-CYCLOHEXYLENE ESTER;
(DICYCLOHEXYLMETHANE-4,4'-DIISOCYANATE)
CAS:5124-30-1
RTECS #:NQ9250000
Fraction by Wt: <10%
OSHA PEL:C 0.01 PPM
ACGIH TLV:0.005 PPM
Ingred Name:SUPDAT:GUINEA PIG. ISOCYANATES REACT W/SKIN PROTEIN &
MOISTURE & CAN CAUSE IRRIT WHICH MAY INCL FOLLOWING SYMPS: (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2:REDDENING, SWELL, RASH, SCALING/BLISTERING. CURED
MATL IS DFCLT TO REMOVE. EXPERIENCE INDICATES DIRECT SKIN(ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:CONT IS ROUTE OF EXPOS MOST LIKELY TO CAUSE SENSIT.
ONCE SENSITIZED, INDIVIDUAL MAY REACT EVEN TO AIRBORNE(ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:LEVELS BELOW TLV W/FOLLOWING SYMPS; ITCHING &
TINGLING OF EARLOBES & NECK, RASH, HIVES, SWELL OF ARMS & (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:LEGS/OTHER SYMPS COMMON TO ALLERGIC DERM. THESE SYMPS
MAY BE IMMED OR DELAYED SEVERAL HRS. EFTS OR OVEREXP:(ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:INHAL OF VAPS/SPRAY MIST MAY ALSO CAUSE IRRIT OF RESP
TRACT (DRY THROAT, COUGH, SHORTNESS OF BREATH, CHEST(ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:TIGHTNESS). SYMPS COULD BE IMMED/DELAYED UP TO
SEVERAL HRS. SIMILAR TO MANY NON-SPECIFIC ASTHMATIC (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:RESPONSES, THERE ARE RPTS THAT ONCE SENSITIZED
INDIVIDUAL CAN EXPERIENCE SYMPS UPON EXPOS TO DUST, COLD (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:AIR/OTHER IRRITANTS. THIS INCR LUNG SENSITIVITY CAN
PERSIST FOR WKS & IN SEV CASES FOR SEVERAL YEARS. (ING 11)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:DUST & VAPORS @ CONCS
ABOVE TLV CAN IRRITATE (BURNING SENSATION) MUC MEMB IN RESP TRACT
(NOSE, THROAT, LUNGS) CAUSING RUNNY NOSE, SORE THROAT, COUGH, CHEST
DISCOMFORT, SHORTNESS OF BREATH & REDUCED LUNG FUNCTION (BRTHG
OBSTRUCTION). PERSONS W/PREEXISTING, NONSPECIFIC BRONCH
HYPERREACTIVITY (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:CAN RESPOND TO CONCS BELOW INTENDED
TLV W/SIMILAR SYMPS AS WELL AS ASTHMA ATTACK. EXPOS WELL ABOVE TLV
MAY LEAD TO BRONCH, BRONCH SPASM & PULM EDEMA (FLUID IN LUNGS).
EFTS ARE USUALLY REVERSI BLE. CHEM/HYPERSENS PNEUM, W/FLU-LIKE
SYMPS (E.G. FEVER, CHILLS), HAS ALSO BEEN RPTD. INGEST:CAN RSLT IN
IRRIT (SUPDAT)
Medical Cond Aggravated by Exposure:EXISTING LUNG CONDITIONS & DERMAL
CONDITIONS MAY BE AGGRAVATED BY USE OF THIS MATERIAL.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/CLEAN, LUKEWARM WATER (LOW PRESS) FOR @ LST 15
MINS, OCCASNLY LIFTING EYE LIDS. OBTAIN IMMED MED ATTN. SKIN:REMOVE
CONTAMD CLTHG. WASH PROMPTLY & THOROUGHLY W/SOAP & WATER. AFTER
WASHING, COVER AFFECTED AREAS W/POLYETHYLENE GLYCOL (300-500
MOL.WT.) & WASH AGAIN W/SOAP & WATER. WASH CONTAMD CLTHG THOROUGHLY
BEFORE REUSE. ALLERGIC DERM SHOULD BE TREATED BY PHYS TO RELIEVE
SYMPS.(ING 13)
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>395F,>202C
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:TOX GASES MAY BE PRESENT AS RSLT OF THERM
DECOMP/COMBUST. CLSD CNTNR MAY EXPLODE WHEN EXPOS TO EXTREME HEAT.
USE COLD WATER SPRAY TO COOL FIRE EXPOS (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:CONSULT SPEC HNDLG INFO SECTION FOR PROPER
PROT EQUIP. EVAC NON ESSNTL PERS. VENTILATE AREA. DIKE/IMPOUND
SPILLED MATL & CONTROL FURTHER SPILLAGE IF FEASIBLE. NOTIFY APPROP
AUTH IF NEC. COVER SPILL W/ SAWDUST, VERMICULITE, FULLER'S EARTH
OR(ING 19)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STOR TEMP (MIN/MAX):32F (0C)/122F
(50C). KEEP AWAY FROM HEAT, SPARKS AND OPEN FLAME.
Other Precautions:STORE IN TIGHTLY CLOSED CONTAINER AND PROTECT FROM
MOISTURE AND FOREIGN MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESP THAT IS REC/APPRVD FOR USE IN ISOCYANATE
CONTAINING ENVIR (NIOSH APPRVD AIR PURIFYING/FRESH AIR SUPPLIED)
MAY BE NEC. FOR SPECIFIC RESPIRATOR INFO CONTACT NEHC .
Ventilation:EXHAUST VENTILATION SUFFICIENT TO KEEP AIRBORNE
CONCENTRATIONS BELOW TLV MUST BE UTILIZED. (ING 23)
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . COVER
AS MUCH OF EXPOS SKIN AREA AS POSS W/APPROP CLTHG, APRON, PROT
SUIT.
Work Hygienic Practices:USE GOOD HYGIENE.
Supplemental Safety and Health
EXPLO HAZ:CNTNRS TO REDUCE RISK OF RUPTURE. CLSD CNTNR MAY ALSO BURST
IF CONTAMD W/WATER DUE TO CO*2 EVOLVED. EFTS OF OVEREXP:& CORR
ACTION IN MOUTH, STOM TISS & DIGESTIVE TRACT. EYE:MILD IRRITANT; RE
VERSIBLE-RABBIT. LIQ, AEROSOLS/VAPS AREIRRIT & CAN CAUSE TEARING,
REDDENING & SWELL. SKIN:IRRITANT & SENSITIZER-(ING 2)
================== Physical/Chemical Properties ==================
Vapor Pres:0.001 @25C
Vapor Density:>1
Spec Gravity:1.06 (H*2O=1)
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:REACTS
Appearance and Odor:CLEAR VISCOUS LIQUID, NO DISTINCT ODOR.
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MOISTURE & OTHER MATERIALS THAT REACT WITH ISOCYANATES.
Stability Condition to Avoid:CONTACT W/MOISTURE & OTHER MATERIALS WHICH
REACT W/ISOCYANATES. TEMPERATURES ABOVE MAXIMUM STORAGE
TEMPERATURE.
Hazardous Decomposition Products:OXIDES OF NITROGEN, HYDROGEN CYANIDE,
CARBON DIOXIDE AND CARBON MONOXIDE.
Conditions to Avoid Polymerization:TEMPERATURES ABOVE MAXIMUM STORAGE
TEMPERATURES.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCIN ACCORDING TO ANY LOCAL, STATE & FED REGS.
INCIN IS METH OF CHOICE. EMPTY CNTNRS MUST BE HNDLD W/CARE DUE TO
PROD RESIDUE. DECONTAM OF CNTNRS PRIOR TO DISP IS USUALLY REC. CONT
DISP COMPANY FOR D ETAILS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DIURETIC SALT
CAGE:1U692
CAGE:1U692
CAGE:24150
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM ACETATE
CAS:127-08-2
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) = 3250 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE IRRITATING ON CONTACT WITH
SKIN, EYES OR MUCOUS MEMBRANES.
Explanation of Carcinogenicity:MSDS STATES "THE MATERIAL IS NOT LISTED
(IARC, NTP, OSHA) AS CANCER CAUSING AGENT.
Effects of Overexposure:MAY BE IRRITATING ON CONTACT WITH SKIN, EYES OR
MUCOUS MEMBRANES.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ASSISTANCE FOR ALL CASES OF OVEREXPOSURE. SKIN:
WASH THOROUGHLY WITH SOAP AND WATER. EYES: IMMEDIATELY FLUSH
THOROUGHLY WITH WATER FOR AT LEAST 15 MINUTES. INHALATION: REMOVE
TO FRESH AIR. INGESTION: GET IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE THE AREA OF ALL UNNECESSARY
PERSONNEL. WEAR SUITABLE PROTECTIVE EQUIPMENT. ELIMINATE ANY
IGNITION SOURCES UNTIL AREA IS DETERMINED TO BE FREE FROM EXPLOSION
OR FIRE HAZARD. CONTAIN THE RELEAS E AND ELIMINATE ITS SOURCE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY AREA. DO NOT
BREATHE DUST. DO NOT GET IN EYES, ON SKIN, OR ON CLOTHING.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MATERIAL SHOULD BE HANDLED OR TRANSFERRED IN AN
APPROVED FUME HOOD OR WITH ADEQUATE VENTILATION.
Ventilation:MATERIAL SHOULD BE HANDLED OR TRANSFERRED IN AN APPROVED
FUME HOOD OR WITH ADEQUATE VENTILATION.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:558F,292C
Spec Gravity:1.57
Solubility in Water:APPRECIABLE
Appearance and Odor:WHITE SOLID, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:ACETIC ACID VAPORS, CARBON MONOXIDE,
CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:40
Preparer's Name:WILLIAM D. DARROW
CAGE:FO588
CAGE:OO505
CAGE:FO588
CAGE:28558
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 100%
Other REC Limits:0.05 MG/CUM NIOSH
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: CRYSTALLINE FIBER SILICON
DUST MAY CAUSE LUNG SCARRING/INJURY W/COUGH & SHORTNESS OF BREATH,
SILICOSIS DISABLING/FATAL PULMONARY FIBROSIS. EYES: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: CRYSTALLINE FIBER SILICON DUST MAY
CAUSE LUNG SCARRING/INJURY WITH COUGH & SHORTNESS OF BREATH,
SILICOSIS DISABLING/FATAL PULMONARY FIBROSIS. EYES: IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: WASH WITH LARGE AMOUNTS OF WATER. GET MED ATTN.
EXAMINATION OF THE RESPIRATORY & CARDIOVASCULAR SYSTEM SHOULD BE
STRESSED.
===================== Fire Fighting Measures =====================
Extinguishing Media:SAND MAY BE USED TO SMOTHER FIRE.
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS W/FULL
FACEPIECE OPERATED IN PRESSURE-DEMAND OR OTHER POSITIVE PRESSURE
MODE.
Unusual Fire/Explosion Hazard:NO FIRE OR EXPLOSION HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEANUP PERSONNEL MUST WEAR PROTECTIVE
EQUIPMENT. COLLECT SPILLED MATERIAL IN DUSTLESS, SAFE MANNER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE DUSTLESS OR WET SYSTEMS WHEN
HANDLING & DURING CLEAN UP.
Other Precautions:MAINTAIN VENTILATION SYSTEM & POST APPROPRIATE
WARNING NOTICES WHERE PRODUCT IS USED, STORED & HANDLED. PRACTICE
GOOD HOUSEKEEPING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATORS MAY BE USED WHEN ENGINEERING & WORK
PRACTICE CONTROLS AREN'T TECHNICALLY FEASIBLE. NIOSH & MSHA
RESPIRATORS ARE PERMITTED IF >TLV.
Ventilation:MAINTAIN GOOD VENTILATION.
Work Hygienic Practices:PRACTICE GOOD HOUSEKEEPING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:4046F
Melt/Freeze Pt:M.P/F.P Text:3050F
Spec Gravity:2.65
Appearance and Odor:WHITE, GRANULAR, NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HYDROFLUORIC ACID (HF)
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:CRYSTALLINE FREE SILICA MAY BE REUSED OR
DISPOSED OF IN AN UNRESTRICTED SANITARY LANDFILL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PRIMADET NONELECTRIC DETONATORS
Preparer's Name:E.L. STEARNS
CAGE:96336
CAGE:96336
============= Composition/Information on Ingredients =============
Ingred Name:PENTAERYTHRITOL TETRANITRATE
CAS:78-11-5
RTECS #:RZ2620000
Fraction by Wt: 30-40%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:LEAD AZIDE
CAS:13424-46-9
RTECS #:OF8650000
Fraction by Wt: 25%
OSHA PEL:RULE IN PROCESS
ACGIH TLV:0.15 MG/M3 PB
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: 10-15%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:LEAD TETROXIDE; (RED LEAD)
CAS:1314-41-6
RTECS #:OG5425000
Fraction by Wt: 10-15%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BARIUM CHROMATE
CAS:10294-40-3
RTECS #:CQ8760000
Fraction by Wt: 1-4%
OSHA PEL:0.5 MG/M3 CR
ACGIH TLV:0.5 MG/M3 CR
Ingred Name:PERCHLORIC ACID, POTASSIUM SALT (1:1); (POTASSIUM
PERCHLORATE)
CAS:7778-74-7
RTECS #:SC9700000
Fraction by Wt: 1-2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICA; (OTTAWA SILICA)
Fraction by Wt: 1-2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CHROMIC ACID, (1:1), LEAD (2+) SALT (1:1); (LEAD CHROMATE)
CAS:7758-97-6
RTECS #:GB2975000
Fraction by Wt: 1-4%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SELENIUM (SARA 313) (CERCLA)
CAS:7782-49-2
RTECS #:VS7700000
Fraction by Wt: <1%
OSHA PEL:0.2 MG/M3
ACGIH TLV:0.2 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
Fraction by Wt: 15-20%
OSHA PEL:10 PPM
ACGIH TLV:10 PPM
Ingred Name:TUNGSTEN
CAS:7440-33-7
RTECS #:YO7175000
Fraction by Wt: 10-15%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:ALUMINUM (SARA 313)
CAS:7429-90-5
RTECS #:BD0330000
OSHA PEL:15 MG/M3 DUST
ACGIH TLV:10 MG/M3 DUST
Ingred Name:LEAD (SARA 313) (CERCLA)
CAS:7439-92-1
RTECS #:OF7525000
OSHA PEL:N/K
ACGIH TLV:0.15 MG/M3 DUST
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:LEAD APPEARS ON THE NAVY LISTING OF
OCCUPATIONAL CHEMICAL REPRODUCTIVE HAZARDS. SEEK CONSULTATION FROM
APPROPRIATE HEALTH PROFESSIONALS CONCERNING LATEST HAZARD LIST
INFORMATION AND SAFE HANDLING AND EXPOSURE INFORMATION . EYE
CONTACT/SKIN CONTACT/INHALATION/INGESTION: NOT LIKELY ROUTES OF
EXPOSURE.
Explanation of Carcinogenicity:BARIUM CHROMATE & LEAD CHROMATE: IARC
MONOGRAPHS, VOL 49, PG 49, 1990:GROUP 1. NTP 7TH ANNUAL REPORT ON
(SUPDAT)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMEDIATELY . EYES: IMMEDIATELY FLUSH EYES
WITH POTABLE WATER FOR AT LEAST 15 MINUTES. SEEK ASSISTANCE FROM MD
. SKIN: FLUSH WITH COPIOUS AMOUNTS OF WATER. CALL MD . INHAL: IF
DETONATION FUMES ARE INHALED,REMOVE TO FRESH AIR. IF NOT BREATHING,
GIVE ARTIFICIAL RESPIRATION, PREFERABLY MOUTH TO MOUTH. IF
BREATHING IS DIFFICULT GIVE OXYGEN. CALL MD.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . DO NOT FIGHT FIRE. ISOLATE AREA. EVACUATE PERSONNEL TO
A SAFE PLACE.
Unusual Fire/Explosion Hazard:HAZARDOUS FUMES PRODUCED IN FIRE ARE LEAD
FUMES AND NITROGEN OXIDES. WILL DETONATE IN A FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:REVIEW FIRE AND EXPLOSION HAZARDS AND SAFETY
PRECAUTIONS BEFORE PROCEEDING WITH CLEAN UP. USE APPROPRIATE
PERSONAL PROTECTION EQUIPMENT DURING CLEAN UP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:TRANSPORTATION AND STORAGE MUST BE IN
ACCORDANCE WITH FEDERAL AND STATE REGULATIONS. CLASS C STANDARD
SHIPPING CONTAINER.
Other Precautions:REFER TO MANUFACTURER'S INSTRUCTIONS AND WARNINGS
SUPPLIED WITH PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE. USE NIOSH APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NOT APPLICABLE.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
APPEAR/ODOR: MG PENTAERYTHRITOL TETRANITRATE (PETN) WITH PLASTIC TUBE
ATTACHED. EXPLAN OF CARCIN: CARCINOGENS, 1994:KNOWN TO BE
CARCINOGEN. NOT ALL HAZARDOUS INGREDIENTS ARE PRESENT IN EVERY
DETONATOR .
================== Physical/Chemical Properties ==================
Appearance and Odor:ALUMINUM SHELL CONTAINING APPROXIMATELY 100 ML LEAD
AZIDE AND 400-800 (SUPDAT)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE WITH ACIDS, ALKALIES.
Stability Condition to Avoid:BECOMES UNSTABLE WITH HEAT, SHOCK,
FRICTION OR IMPACT. AVOID BREATHING FUMES FROM DETONATION.
Hazardous Decomposition Products:HAZARDOUS GASES PRODUCED ARE NITROGEN
OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS . CONSULT AN EXPLOSIVE MANUFACTURER FOR
RECOMMENDED METHODS FOR DESTROYING EXPLOSIVE MATERIALS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SULFAMIC ACID 22200. A295100
Resp. Party Other MSDS Num.:ACC22200 A295100 REVISION #7
CAGE:1B464
CAGE:1B464
CAGE:SO010
============= Composition/Information on Ingredients =============
Ingred Name:SULFAMIC ACID
CAS:5329-14-6
RTECS #:WO5950000
= Wt:100.
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT): 3160 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EMERGENCY OVERVIEW: CAUTION! MAY CAUSE
EYE AND SKIN IRRITATION. MAY CAUSE RESPIRATORY AND DIGESTIVE TRACT
IRRITATION. TARGET ORGANS: NONE. ACUTE: EYES: DUST MAY CAUSE
MECHANICAL IRRITATION. CONCENTRAT ED SOLUTIONS MAY PRODUCE
CORROSIVE EFFECTS. SKIN: MAY CAUSE SKIN IRRITATION, CONTACT WITH
THE LIQUID OR HIGH CONCENTRATION OF VAPORS MAY CAUSE BLISTERING OF
THE SKIN. CONCENTRATED SOLUTIONS MAY PRODUC E CORROSIVE EFFECTS.
INGESTION: MAY CAUSE SEVERE GASTROINTESTINAL TRACT IRRITATION WITH
NAUSEA, VOMITING AND POSSIBLE BURNS. INHALATION: MAY CAUSE
RESPIRATORY TRACT IRRITATION. (EFTS OF OVEREXP)
Effects of Overexposure:HLTH HAZ: CHRONIC: INHALATION AND INGESTION MAY
CAUSE EFFECTS SIMILAR TO THOSE OF ACUTE INHALATION AND INGESTION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH EYES W/PLENTY OF WATER FOR AT LEAST 15 MINUTES,
OCCASIONALLY LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. SKIN:
GET MED AID IMMED. FLUSH SKIN W/PLENTY OF SOAP & WATER FOR AT LEAST
15 MIN WHILE REMOVING CONTAMD CLTHG & SHOES. INGEST: IF VICTIM IS
CONSCIOUS AND ALERT, GIVE 2-4 CUPFULS OF MILK OR WATER. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. GET MEDICAL AID
IMMEDIATELY. INHALATION: GET MEDICAL AID IMMEDIATELY. REMOVE FROM
EXPOSURE TO FRESH AIR IMMEDIATELY. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN.
NOTES TO PHYSICIAN: TREAT
===================== Fire Fighting Measures =====================
Extinguishing Media:USE EXTINGUISHING MEDIA MOST APPROPRIATE FOR THE
SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:COMBUSTION GENERATES TOXIC FUMES. IN CASE
OF FIRE, USE WATER FOG, DRY CHEMICAL, CARBON DIOXIDE, OR REGULAR
FOAM. NFPA RATING: (ESTIMATED) HEALTH: 2; FLAMMABILITY: 0;
REACTIVITY: 0.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTIVE EQUIPMENT AS
INDICATED IN SECTION 8. SWEEP UP OR ABSORB MATERIAL, THEN PLACE
INTO A SUITABLE CLEAN, DRY, CLOSED CONTAINER FOR DISPOSAL. PROVIDE
VENTILATION.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE: STORE IN A COOL, DRY,
WELL-VENTILATED AREA AWAY FROM INCOMPATIBLE SUBSTANCES. KEEP
CONTAINERS TIGHTLY CLOSED.
Other Precautions:HANDLING: WASH THOROUGHLY AFTER HANDLING. USE ONLY IN
A WELL VENTILATED AREA. AVOID CONTACT WITH EYES, SKIN, AND
CLOTHING. AVOID INGESTION AND INHALATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
29 CFR 1910.134 OR EUROPEAN STANDARD EN 149. ALWAYS USE A NIOSH OR
EUROPEAN STANDARD EN 149 APPROVED RESPIRATOR WHEN NECESSARY.
Ventilation:USE ADEQUATE VENTILATION TO KEEP AIRBORNE CONCENTRATIONS
LOW.
SKIN EXPOS.
.
Other Protective Equipment:ANSI APPROVED EYE WASH AND DELUGE SHOWER .
WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
PHYSICAL: MOLECULAR FORMULA: H3 N 03 S. MOLECULAR WEIGHT: 97.1.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:DECOMPOSES
Melt/Freeze Pt:=200.C, 392.F
Decomp Temp:=205.C, 401.F
Vapor Pres:NOT AVAIL
Vapor Density:NOT AVAIL
Spec Gravity:/ DENSITY: 2.15
pH:1.2
Solubility in Water:SOLUBLE
Appearance and Odor:WHITE SOLID; ODORLESS.
Percent Volatiles by Volume:NOT AVAIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HYPOCHLOROUS ACID, HYPOCHLORITES, CYANIDES AND SULFIDES. A VIOLENT OR
EXPLOSIVE REACTION OCCURS WITH CHLORINE; METAL NITRATES + HEAT;
METAL NITRITES + HEAT, AND FUMING NITRIC ACID.
Stability Condition to Avoid:INCOMPATIBLE MATERIALS, EXCESS HEAT.
Hazardous Decomposition Products:NITROGEN OXIDES, OXIDES OF SULFUR,
AMMONIA AND/OR DERIVATIVES.
Conditions to Avoid Polymerization:HAS NOT BEEN REPORTED.
=================== Toxicological Information===================
Toxicological Information:RTECS#: CAS #: 5329-14-6; WO5950000.
LD50/LC50: CAS#: 5329-14-6: ORAL, MOUSE: LD50=1312 MG/KG.
CARCINOGENICITY: SULFAMIC ACID: NOT LISTED BY ACGIH, IARC, NIOSH,
NTP, OR OSHA. EPIDEMIOLOGY, TERATOGENIC ITY, REPRODUCTIVE EFFECTS,
NEUROTOXICITY, MUTAGENICITY, OTHER STUDIES: NO DATA AVAILABLE.
===================== Ecological Information =====================
Ecological:ECOTOXICITY, ENVIRONMENTAL FATE, PHYSICAL/CHEMICAL, OTHER:
NOT AVAILABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE AND LOCAL REGULATIONS. RCRA P-SERIES: NONE LISTED. RCRA
U-SERIES: NONE LISTED.
=================== MSDS Transport Information ===================
Transport Information:US DOT SHIPPING NAME: SULFAMIC ACID. HAZARD
CLASS: 8. UN NUMBER: UN 2967. PACKING GROUP: III. IMO SHIPPING
NAME: SULPHAMIC ACID. HAZARD CLASS: 8. UN NUMBER: 2967. PACKING
GROUP: III. IATA SHIPPING NAM E: SULPHAMIC ACID. HAZARD CLASS: 8.
UN NUMBER: 2967. PACKING GROUP: III. RID/ADR SHIPPING NAME:
SULPHAMIC ACID. DANGEROUS GOODS CODE: 8(11C). UN NUMBER: 2967.
CANADIAN TDG SHIPPING NAME: SULFAMIC ACID . HAZARD CLASS: 8. UN
NUMBER: UN2967.
===================== Regulatory Information =====================
SARA Title III Information:SARA SECTION 302 (RQ): NONE OF THE CHEMICALS
IN THIS MATERIAL HAVE AN RQ. SECTION 302 (TRQ): NONE OF THE
CHEMICALS IN THIS PRODUCT HAVE A TPQ. SARA CODES: CAS # 5329-14-6:
ACUTE. SECTION 313: NO CHEMI CALS ARE REPORTABLE UNDER SECTION 313.
CLEAN AIR ACT: THIS MATERIAL DOES NOT CONTAIN ANY HAZARDOUS AIR
POLLUTANTS, CLASS 1 OZONE DEPLETORS, CLASS 2 OZONE DEPLETORS. CLEAN
WATER ACT: NONE OF THE CHEMIC ALS IN THIS PRODUCT ARE LISTED AS
HAZARDOUS SUBSTANCES, PRIORITY POLLUTANTS & TOXIC POLLUTANTS UNDER
CWA.
Federal Regulatory Information:TSCA: CAS# 5329-14-6 IS LISTED ON THE
TSCA INVENTORY. HEALTH & SAFETY REPORTING LIST: NONE OF THE
CHEMICALS ARE ON THE HEALTH & SAFETY REPORTING LIST. CHEMICAL TEST
RULES: NONE OF THE CHEMICALS IN THI S PRODUCT ARE UNDER A CHEMICAL
TEST RULE. SECTION 12B: NONE OF THE CHEMICALS ARE LISTED UNDER TSCA
SECTION 12B. TSCA SIGNIFICANT NEW USE RULE: NONE OF THE CHEMICALS
IN THIS MATL HAVE A SNUR UNDER TSCA . CANADA: CAS#: 5329-14-6 IS
LISTED ON CANADA'S DSL/NDSL LIST. THIS PRODUCT HAS A WHMIS
CLASSIFICATI ON OF E. OSHA-NONE OF THE CHEM IN PROD CONSIDERED
HIGHLY HAZ BY OSHA.
State Regulatory Information:SULFAMIC ACID CAN BE FOUND ON THE
FOLLOWING STATE RIGHT TO KNOW LIST: NEW JERSY. CALIFORNIA NO
SIGNIFICANT RISK LEVEL: NONE OF THE CHEMICALS IN THIS PRODUCT ARE
LISTED. EUROPEAN/INTERNALTIONAL REGULAT IONS: EUROPEAN LABELING IN
ACCORDANCE WITH EC DIRECTIVE. HAZARD SYMBOLS: XI. RISK PHASES: R
36/38 IRRITATING TO EYES AND SKIN. SAFETY PHASES: S 26 IN CASE OF
CONTACT WITH EYES, RINSE IMMEDIATELY WITH PLENTY OF WATER AND SEEK
MEDICAL ADVICE. S 28 AFTER CONTACT WITH SKIN, WASH IMMEDIATELY WITH
PLENTY OF ... (TO BE SPECIFIED BY THE MFR). WGK (WATER
DANGER/PROTECTION) CAS # 5329-14-6.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:STRONTIUM HYDROXIDE ANHYDROUS, 4046
CAGE:DO811
CAGE:DO811
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:STRONTIUM HYDROXIDE
CAS:18480-07-4
RTECS #:WK9100000
Fraction by Wt: 90-100%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NO EFFECTS OF OVEREXPOSURE WERE
DOCUMENTED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:CALL MD. INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
O*2/ARTF RESP) . INGEST:IF CONSCIOUS, IMMEDIATELY INDUCE VOMITING.
EYES:IMMEDIATELY FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINUTES. S
KIN:FLUSH W/WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
MOVE EXPOS CNTNRS FROM FIRE AREA IF IT CAN BE DONE W/OUT RISK. USE
WATER TO KEEP FIRE-EXPOS CNTNRS COOL.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT CLTHG.
WITH CLEAN SHOVEL, CAREFULLY PLACE MATL INTO CLEAN, DRY CNTNR &
COVER; REMOVE FROM AREA. FLUSH SPILL AREA W/WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED.
SUITABLE FOR ANY GENERAL CHEMICAL STORAGE AREA.
Other Precautions:WARNING! HARMFUL IF SWALLOWED. CAUSES IRRITATION.
AVOID CONTACT W/EYES, SKIN, CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCENTRATION IS HIGH, USE
APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR OR DUST MASK.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
FUME OR DUST LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:LAB COAT, UNIFORM, APRON ARE RECOMMENDED.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:707F,375C
Spec Gravity:3.63 (H*2O=1)
Solubility in Water:SLIGHT (0.1-1%)
Appearance and Odor:COLORLESS, DELIQUESCENT CRYSTALS.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE DOCUMENTED.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W ALL APPLICABLE FEDERAL, STATE &
LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LUBRICATING OIL (WATER SOLUBLE) VV-C-846A
Preparer's Name:DENNIS KROL
CAGE:EO110
CAGE:61808
CAGE:60226
CAGE:EO110
============= Composition/Information on Ingredients =============
Ingred Name:SEVERLY HYDROTREATED HEAVY NAPHTHENIC DISTILLATE (MINERAL
OIL)
CAS:64742-52-5
RTECS #:PY8035000
Fraction by Wt: 85%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM SULFONATE
CAS:68608-26-4
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 AS OIL MIST
ACGIH TLV:5 MG/M3 AS OIL MIST
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 2%
Other REC Limits:NONE RECOMMENDED
Ingred Name:2-BUTOXYETHANOL (SARA III) (DOWANOL EB)
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 1.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9394
Ingred Name:TALL OIL- SODIUM SALT
CAS:65997-01-5
Fraction by Wt: 2.0%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:5MG/M3 FOR MINERAL OIL, OSHA 1992.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYE:MILD (TRANSIENT) IRRIT. NOT
CORROSIVE. NO SENSITIZATION. INHAL:PER MFG LUNG EFFECTS UNKNOWN.
Effects of Overexposure:EYE:REDNESS, TEARING. SKIN:REDNESS, DISCOMFORT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:DO NOT INDUCE VOMITING. GET MED ATTN. SKIN:REMOVE
CONTAMINATED CLOTHING. FLUSH W/SOAP & WATER. EYE:FLUSH W/PLENTY OF
WATER FOR @ LEAST 15MINS. GET MED ATTN. INHAL:REMOVE TO FRESH AIR.
IF NOT BR EATH, GIVE ARTIFICIAL RESPIRATION. GIVEOXYGEN. GET MED
ATTN.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:350F,177C
Extinguishing Media:WATER FOG, CARBON DIOXIDE, DRY CHEMICAL, FOAM,
EARTH OR SAND.
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH SAND OR INERT MATERIAL. SWEEP OR
SCOOP UP AND REMOVE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED & AWAY FROM
SPARKS & OPEN FLAMES. DO NOT BREATH VAPOR/MIST. DO NOT GET IN EYES
OR ON CLOTHING.
Other Precautions:THIS PRODUCT IS NORMALLY USED IN DILUTED FORM (20
PARTS OF WATER TO 1 PART FLUID). THERE IS NO FLASH POINT UNDER
THESE CONDITIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE ONLY NIOSH/MESA APPROVED RESPIRATOR WITH
FILTER FOR DUST/FUME/MIST.
Ventilation:USE LOCAL EXHAUST TO ALWAYS MAINTAIN EXPOSURE BELOW
PERMISSIBLE EXPOSURE LIMITS.
Other Protective Equipment:APRON, EYE WASH.
Work Hygienic Practices:WASH HANDS AFTER HANDLING MATERIAL & BEFORE
EAT/SMOKE/DRINK. LAUNDRY CONTAMINATED CLOTHING PRIOR TO REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:700F,371C
Spec Gravity:0.92
Solubility in Water:COMPLETE
Appearance and Odor:FLUID OIL-BLAND.
Percent Volatiles by Volume:2
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE IF
INCOMPLETE COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:ALL DISPOSALS MUST COMPY WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
Product ID:AEROSOL SPTAY PAINT, AP220 MEDIUM GRAY
CAGE:25461
CAGE:25461
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENT NAPHTHA; (AROMATIC HYDROCARBON). VP: 10 @ 20C.
CAS:64742-94-5
RTECS #:WF3100000
Other REC Limits:100 PPM (MFR)
Ingred Name:NAPHTHA, MEDIUM ALIPHATIC; (MEDIUM MINERAL SPIRITS). VP: 2
@ 20C.
CAS:64742-88-7
Other REC Limits:100 PPM (MFR)
Ingred Name:VM & P NAPHTHA. VP: 26 @ 100F.
CAS:64742-89-8
Ingred Name:METHANE, DICHLORO-; (METHYLENE CHLORIDE). 400 @ 20C.
CAS:75-09-2
RTECS #:PA8050000
OSHA PEL:500 PPM; 1000, C
ACGIH TLV:50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:NON-HAZARDOUS POLYMER (TYPE NOT SPECIFIED)
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:COBALT OCTOATE %6
CAS:136-52-7
OSHA PEL:0.05 MG/M3 (CO)
ACGIH TLV:0.05 MG/M3 (CO)
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:ACETIC ACID, BUTYL ESTER; (BUTYL ACETATE). VP: 8 @ 20C.
CAS:123-86-4
RTECS #:AF7350000
OSHA PEL:150 PPM;200 PPM STEL
ACGIH TLV:150 PPM;200 PPM STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:HYDROTREATED HEAVY NAPHTHA (PETROLEUM); (HEAVY NAPHTHA)
CAS:64742-48-9
Other REC Limits:100 PPM (MFR)
Ingred Name:IRON OXIDE
CAS:1309-37-1
RTECS #:NO7400000
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
Ingred Name:OTHER PREC: APPROVED RESPIRATOR OR APPROPRIATE VENTILATION.
DO NOT SPRAY NEAR FIRE OR OPEN FLAME. NOTE:TOLUENE (ING 18)
RTECS #:9999999ZZ
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3 (FE)
Ingred Name:ING 17:CAS#1088-88-3 APPEARS ON THE NAVY LISTING OF OCCUP
REPRP HAZ. SEEK CONSULTATION FROM APPROP HEALTH (ING 19)
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
Ingred Name:ING 18:PROFESSIONALS CONCERNING LATEST HAZARD LIST INFO AND
SAFE HANDLING AND EXPOSURE RECOMMENDATIONS .
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BUTYL ALCOHOL; (N-BUTYL ALCOHOL). VP: 5.5 @ 20C.
CAS:71-36-3
RTECS #:EO1400000
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENE. VP: 25 @ 20C.
CAS:1330-20-7
RTECS #:ZE2100000
OSHA PEL:50 PPM, S, C
ACGIH TLV:50 PPM, S, C
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SOLVENT NAPHTHA, (PETROLEUM), LIGHT AROMATIC; (AROMATIC
HYDROCARBON). VP: 10 @ 20C.
CAS:64742-95-6
RTECS #:WF3400000
Other REC Limits:50 PPM (MFR)
OSHA PEL:25 PPM (MFR)
ACGIH TLV:25 PPM (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INGEST: GI DISTRESS. INHAL: OVEREXP
MAY CAUSE NOSE & THROAT IRRIT. MAY CAUSE CNS EFTS SUCH AS DIZZ,
HDCH, NAUS, STAGGERING GAIT, CONFUSION & UNCON. REPORTS HAVE ASSOC
RPTD & PRLNGD OVEREXP TO SOLVS W/ PERM BRAIN & NERVS SYS DAM. EYE
WATERING, HDCHS, NAUS, DIZZ & LOSS OF COORDINATION ARE SIGNS THAT
(EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:METHYLENE CHLORIDE: GROUP 2B (IARC),
ANTICIPATED TO BE A CARCIN (NTP);COBALT COMPOUNDS(COBALT OCTOATE)
IARC GROUP 2B.
Effects of Overexposure:HLTH HAZ: SOLV LVLS ARE TOO HIGH. EYE: MAY
CAUSE IRRIT/BURNING. SKIN: RPTD/PRLNGD LIQ CONT MAY CAUSE IRRIT
W/DISCOMFORT & DERM. CHLOROCARBON/CHLOROFLUOROCARBON (CFC) MATLS
HAVE PRDCED SENSIT OF THE MY OCARDIUM TO EPINEPHRINE IN LAB ANIMALS
& COULD HAVE A SIMILAR EFFECT IN HUMANS. ADRENOMIMETICS (E.G.,
(SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY AND HAVE NAMES OF INGREDIENTS
AVAILABLE. DO NOT INDUCE VOMITING. INHAL: REMOVE TO FRESH AIR. IF
NOT BRTHG, GIVE ARTIFICIAL RESPIRATION, PREF MOUTH TO MOUTH. IF
BRTHG DIFFICU LTY PERSISTS/OCCURS LATER, CONSULT MD. SKIN:WASH WITH
SOAP & WATER. IF IRRIT OCCURS CONTACT MD. EYES: IMMEDIATLEY FLUSH
WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES; CALL MD.
===================== Fire Fighting Measures =====================
Flash Point:<20F/<-7C
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE SOURCES OF IGNITION.
PREVENT SKIN CONTACT AND BREATHING OF VAPOR. CONFINE AND REMOVE
WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:OBSERVE LABEL PRECS. KEEP AWAY FROM
HEAT, SPKS & FLAME. DO NOT STORE >120F. DO NOT EXPOSE TO DIRECT
SUNLIGHT TO AVOID BURSTING. DO NOT PUNCTURE.
Other Precautions:NO SMOKING IN AREA OF USE. DO NOT USE IN GEN VICINITY
OF ARC WELDING, OPEN FLAMES/HOT SURFS. HEAT &/UV RADIATION MAY
CAUSE FORMATION OF HCL &/PHOSGENE . DO NOT SAND, FLAME CUT,
BRAZE/WELD DRY CO ATING W/OUT NISOH/MSHA (ING 17)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DO NOT BREATHE VAPS/MISTS. WEAR APPROP, PROPERLY
FITTED NIOSH/MSHA APPRVD RESPIRATOR DURING & AFTER APPLICATION
UNLESS AIR MONITORING DEMONSTRATES VAP/MIST LVLS ARE < APPLIC LIMS.
FOLLOW RESPIRATOR MF R'S DIRECTIONS FOR RESPIRATOR USE.
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME AND PATTERN TO
KEEP CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Other Protective Equipment:COVERALLS.
Work Hygienic Practices:WASH THORO AFTER HANDLING & BEFORE EATING &
SMOKING. PROT CREAMS MAY BE USED FOR EASE OF CLEAN-UP, NOT FOR
PROTECTION.
Supplemental Safety and Health
BP:<0F,<-18C (PROPELLANT).SOL IN H*2O:MOD - APPRECIABLE, DEPENDING ON
COLOR.EXPLO HAZ:PROPELLING CONTENTS ACROSS AREA. HLTH
HAZ:EPINEPHRINE) MAY BE CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINING
USES IN H UMANS ACUTELY/CHRONICALLY EXPOS TO CHLOROCARBON/CFC'S. .
FOR HLTH HAZ ASSOC W/INDIVIDUAL INGS CONTACT NEHC .
================= Stability and Reactivity Data =================
Hazardous Decomposition Products:HCL, PHOSGENE . CO, CO*2, SMOKE,
OXIDES OF HEAVY METALS REPORTED IN INGREDIENTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. INCINERATE ABSORBED MATERIAL I/A/W FEDERAL, STATE
AND LOCAL REQUIREMENTS. DO NOT INCINERATE IN CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:KGL3100
CAGE:14655
CAGE:14655
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR. AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UN CONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ECCOBOND 286,BLACK-PART A
Kit Part:Y
CAGE:MO777
CAGE:02750
CAGE:MO777
CAGE:04552
============= Composition/Information on Ingredients =============
Ingred Name:N-BUTYL GLYCIDYL ETHER (BGE)
CAS:2426-08-6
RTECS #:TX4200000
Fraction by Wt: <2.0%
OSHA PEL:50 PPM
ACGIH TLV:25 PPM; 9293
Ingred Name:EPICHLOROHYDRIN (SARA III)
CAS:106-89-8
RTECS #:TX4900000
Fraction by Wt: <5%PPM
OSHA PEL:S, 5 PPM
ACGIH TLV:S, 2 PPM; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:NON-HAZ INGR:BISHENOL A/EPICHLORE HYDRIN-BASED EPOXY
RESIN,NON-HAZ.MINERAL FILLERS,PIGMENTS,NON-HAZ MODIFIERS.
Fraction by Wt: >98.0%
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYE:IRRITATION;SKIN:IRRITATION,SKIN
SENSITIZATION,INHALATION:IRRITATION;INGESTION:HARMFUL IF SWALLOWED.
Explanation of Carcinogenicity:NTP LISTS EPICHLOROHYDRIN AS PROPOSED
FOR ADDITION TO ITS 5TH ANNUAL REPORT AS REASONABLY ANTICIPATED
CARCINOGEN.
Effects of Overexposure:SEE HEALTH HAZARDS
Medical Cond Aggravated by Exposure:NONE NOTED
======================= First Aid Measures =======================
First Aid:EYE:FLUSH WITH WATER FOR 15 MIN.GET MEDICAL
ATTENTION;SKIN:REMOVE CONTAMINATED CLOTHING.WASH AFFECTED AREA WITH
WATER;INHALATION:REMOVE TO FRESH AIR,INGESTION:DILUTE WITH LARGE
QUANTITIES OF WATER.IF CONSCIOUS & ALERT,INDUCE VOMIT.GET
IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:240F,116C
Extinguishing Media:CO*2,DRY CHEMICAL,FOAM,WATER FOG
Fire Fighting Procedures:FIREFIGHT SHOULD WEAR SCBA.
Unusual Fire/Explosion Hazard:TOXIC FUMES MAY BE EVOLVED UPON EXPOSURE
TO HEAT OR OPEN FLAMES,OR IF HEAT OF REACTION BECOMES EXCESSIVE DUE
TO HIGH CURING TEMPERATURE OR CURING OF LARGE MASSE
================== Accidental Release Measures ==================
Spill Release Procedures:SM SPILL:VENTILATE.OBSERVE FIRE
PRECAUTIONS.ABSORB IN INERT MATERIAL.COLLECT IN SEALED
CONTAINERS.SCRUB W/SOAPY WTR & RINSE. LG SPILL*DIKE.PUMP INTO
SALVAGE TANK.ABSORB IN INERT MATERIAL.SHOVEL INTO C ONTAINERS.SCRUB
W/SOAPY WATER & RINSE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY PLACE.KEEP REMOVED
FROM ANY HEAT OR OPEN FLAME.KEEP CONTAINER CLOSED WHEN NOT IN USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID BREATHING VAPOR.USE ONLY WITH ADEQUATE
VENTILATION.
Ventilation:FLEXIBLE DUCTWORK SHOULD EXTEND TO AREAS OF HIGH
CONCENTRATION.PROVIDE SPECIAL VENTILATION AT ELEVATED TEMPERATURES.
Other Protective Equipment:PROTECTIVE CLOTHING.
Work Hygienic Practices:STANDARD HYGENIC PRACTICES
Supplemental Safety and Health
N/R.KEY1:N1.
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Pres:<1
Vapor Density:>1
Spec Gravity:2.35
Solubility in Water:NEFLIGIBLE
Appearance and Odor:BLACK PASTE
Percent Volatiles by Volume:<2.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.AMINES.AMIDES.STRONG LEWIS OR MINERAL
ACIDS.THIOSULFATES.CARBOXYLIC ACIDS ALCOHOL,MERCAPTANS.
Stability Condition to Avoid:STORAGE IN OPEN CONTAINERS. EXPOSURE TO
HEAT AND/OR OPEN FLAM.
Hazardous Decomposition Products:CO,CO*2,OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:SPILLED MATERIAL & WATER RINSES ARE CLASSIFIED
ASCHEMICAL WASTE,& MUST BE DISPOSED OF IAW APPLICABLE
FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ACRYLIC LIQUID HEAT CURE
CAGE:FO479
CAGE:65024
CAGE:FO479
============= Composition/Information on Ingredients =============
Ingred Name:METHYL METHACRYLATE (SARA III)
CAS:80-62-6
RTECS #:OZ5075000
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RATS): 7900 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NOSE & THROAT IRRITATION,
CENTRAL NERVOUS SYSTEM EFFECTS, DIZZINESS, HEADACHE, NAUSEA, & LOSS
OF CONSCIOUSNESS. SKIN/EYES: IRRITATION, CORNEAL INJURY, ALLERGIC
RASH, ITCHING, SWELLING, & S ENSITIZER.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: NOSE & THROAT IRRITATION, CENTRAL
NERVOUS SYSTEM EFFECTS, DIZZINESS, HEADACHE, NAUSEA, & LOSS OF
CONSCIOUSNESS. SKIN/EYES: IRRITATION, CORNEAL INJURY, ALLERGIC
RASH, ITCHING, SWELLING, & S ENSITIZER.
Medical Cond Aggravated by Exposure:ALLERGIC RASH
======================= First Aid Measures =======================
First Aid:INGESTION: INDUCE VOMITING & GET PROMPT MED ATTN. INHALATION:
REMOVE TO FRESH AIR. IF BREATHING DIFFICULTY, ADMINISTER OXYGEN. IF
NOT BREATHING, ADMINISTER ARTIFICIAL RESPIRATION. CALL PHYSICIAN.
EYES : FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINUTES. CALL
PHYSICIAN. SKIN: WASH W/SOAP & WATER. CONTACT PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:50F
Lower Limits:1.8%
Upper Limits:8.2%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE UNLESS IT IS USED AS
FINE SPRAY OR FOG.
Unusual Fire/Explosion Hazard:EXPOSURE TO DIRECT HEAT, FLAMES CAN
INDUCE POLYMERIZATION WITH RAPID RELEASE OF ENERGY.
================== Accidental Release Measures ==================
Spill Release Procedures:MOP UP & WASH W/WATER. KEEP ROOM WELL
VENTILATED. DIKE & ABSORB SPILL W/INERT MATERIAL SAND, SODA ASH,
VERMICULITE AREA.
Neutralizing Agent:SODA ASH
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL ROOM. AVOID EXPOSURE TO
HEAT, DIRECT SUN, SPARKS, OR FLAME. AVOID CONTACT W/SKIN & EYE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL EQUIPMENT NECESSARY.
Ventilation:PROVIDE LOCAL EXHAUST/MECHANICAL VENTILATION TO KEEP <TLV.
Other Protective Equipment:NOT NORMALLY REQUIRED
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:101 F
Vapor Pres:29.0
Vapor Density:3.46
Spec Gravity:0.9497
Evaporation Rate & Reference:(BU AC = 1): 3
Solubility in Water:1.60
Appearance and Odor:CLEAR LIQUID W/FRUITY ACRYLIC ODOR.
Percent Volatiles by Volume:99.75%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REDUCING & OXIDIZING MATERIALS
Stability Condition to Avoid:HEAT, DIRECT SUNLIGHT, IGNITION SOURCES,
SPARKS, & FLAME.
Hazardous Decomposition Products:ACRID FUMES, CO, CO2 SMOKE
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE UNDER CONTROLLED CONDITION WHICH
COMPLIES W/FEDERAL, STATE, & LOCAL REGULATIONS. EPA LISTED HAZARDS
WASTE UNDER RCRA (U-162).
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:182-188 LETTERPRESS
Preparer's Name:DICK KARBO
CAGE:KMADD
CAGE:KMADD
============= Composition/Information on Ingredients =============
Ingred Name:BARIUM COMPOUNDS
Fraction by Wt: 21%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED CONTACT W/SKIN/EYES CAN
CAUSE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMEDIATELY W/WATER. SKIN: WASH AFFECTED AREA
W/SOAP & WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>200F
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: WIPE UP & STORE WIPERS IN UNDERWRITERS
APPROVED CONTAINERS. LARGE: SCOOP MATERIAL INTO SEALABLE
CONTAINERS. WIPE UP REMAINDER & STORE WIPERS IN UNDERWRITERS
APPROVED CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS.
Other Precautions:AVOID CONTACT W/SKIN, EYES & CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS REQUIRED
Ventilation:LOCAL EXHAUST
Work Hygienic Practices:WASH AFTER USE. REMOVE/LAUNDER CONTAMINATED
CLOTHING BEFORE REUSE. DON'T CONSUME FOOD/BEVERAGE WHERE PRODUCT IS
USED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:470-610F
Evaporation Rate & Reference:SLOWER THAN WATER
Solubility in Water:INSOLUBLE
Appearance and Odor:OILY
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:27-200 WALLHYDE S.G. DEEPTONE BASE
CAGE:47695
CAGE:47695
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9394
Ingred Name:CALCIUM CARBONATE
CAS:471-34-1
RTECS #:FF9335000
Fraction by Wt: 20-25%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TOTAL DUST
ACGIH TLV:10 MG/M3
Ingred Name:HYDROTREATED HEAVY NAPHTHA
CAS:64742-48-9
Fraction by Wt: 35-40%
Other REC Limits:NONE RECOMMENDED
Ingred Name:FILM,FORMERS,RESINS & ADDITIVES
Fraction by Wt: 25-30%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: HARMFUL OR FATAL IF INGESTED.
CONTACT MAY CAUSE SKIN & EYE IRRITATION. INHALATION MAY CAUSE
RESPIRATORY TRACT IRRITATION; MAY BE HARMFUL. CHRONIC: NONE
SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:INHALED: COUGHING, SNEEZING, WHEEZING, SORE
THROAT, DIZZINESS, DROWSINESS, HEADACHE, NAUSEA, VOMITING. EYES:
REDNESS, BLURRED VISION, BURNING SENSATION, VISUAL DISTURBANCES.
SKIN: REDNESS, DRYNESS, CR ACKING, SWELLING, ITCHING, DISCOMFORT.
INGESTED: NAUSEA, VOMITING, DIARRHEA,
Medical Cond Aggravated by Exposure:NOT APPLICABLE.
======================= First Aid Measures =======================
First Aid:INGESTED-DO NOT INDUCE VOMITING! EYES-FLUSH WITH LOTS OF
WATER FOR AT LEAST 15 MINUTES. SKIN-FLUSH WITH LOTS OF WATER
FOLLOWED BY WASHING WITH SOAP & WATER. INHALED-REMOVE TO FRESH AIR.
APPLY ARTIFICI AL RESPIRATION OR OTHER SUPPORT MEASURES AS
REQUIRED. OTHER-IF INGESTED, OR IF SYMPTOMS OCCURS, CONTACT A
POISON CONTROL CENTER, EMERGECY ROOM OR PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:120F,49C
Lower Limits:0.7
Extinguishing Media:USE CARBON DIOXIDE,FOAM (AFFF),OR DRY CHEMICAL.USE
CLASS B AGENTS/FIRE EXTINGUISHERS.WATER MAY BE INEFFECTIVE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:CONTAINERS MAY EXPLODE IF EXPOSED TO
FIRE. COMBUSTION OR HEAT OF FIRE MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:PROVIDE MAXIMUM VENTILATION. ONLY PERSONNEL
WITH PROPER PROTECTIVE EQUIPMENT/CLOTHING ALLOWED IN SPILL AREA.
REMOVE ALL SOURCES OF IGNITION. TAKE UP WITH INERT ABSORBENT AND
PLACE IN A CONTAINER FOR D ISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. STORE IN A
BUILDING DESIGNED FOR NFPA CLASS II COMBUSTIBLE MATERIALS.
Other Precautions:CONTAINERS SHOULD BE GROUNDED & BONDED WHEN
POURING/TRANSFERRING. THIS MATERIAL IS PART OF A MULTIPLE COMPONENT
SYSTEM; TAKE INTO ACCOUNT OTHER PART(S) OF THE SYSTEM (READ THEIR
MSDS).
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE
OR EMERGENCY OCCURS; USE NIOSH/MSHA APPROVED RESPIRATOR OR SUPPLIED
AIR RESPIRATOR OR SCBA, AS REQUIRED. USE IAW 29 CFR 1910.134 AND
MANUFACTURER'S RECO MMENDATIONS.
Ventilation:EXPLOSION-PROOF LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST
ACCEPTABLE IF THE EXPOSURE IS MAINTAINED BELOW TLV.
Other Protective Equipment:INDUSTRIAL-TYPE WORK CLOTHING, HAT AND APRON
AS REQUIRED.
Work Hygienic Practices:USE WITH ADEQUATE VENTILATION. AVOID BREATHING
VAPOR/SPRAY MIST. AVOID CONTACT WITH SKIN & EYES. WASH HANDS AFTER
USE.
Supplemental Safety and Health
MSDS ENTERED BY DLA-HMIS UNDER PROJECT FOR GSA.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:0.7 MM HG
Vapor Density:>1
Spec Gravity:1.1
Evaporation Rate & Reference:6 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:VISCOUS LIQUID; SOLVENT ODOR.
Percent Volatiles by Volume:59.6
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG MINERAL ACIDS, STRONG ALKALIS, STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL ENVIRONMENTAL REGULATIONS. EMPTY CONTAINERS SHOULD BE
RECYCLED OR DISPOSED OF THROUGH AN APPROVED WASTE MANAGEMENT
FACILITY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:S218, SYSTEM 2 GLOSS VINYL SCREEN INK-SCARL
CAGE:0U879
CAGE:0U879
============= Composition/Information on Ingredients =============
Ingred Name:PIGMENT; (PIGMENTS, MIXTURE). PEL: 15 MG/M3 (AS DUST)
(MFR). TLV: 10 MG/M3 (AS DUST) (MFR).
Fraction by Wt: 0-30%
OSHA PEL:SEE INGREDIENT NAME
ACGIH TLV:SEE INGREDIENT NAME
Ingred Name:LEAD; (LEAD COMPOUNDS) (SARA III) (CAS# & EXPOSURE LIMITS
ARE FOR INORGANIC LEAD DUSTS & FUMES)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 5-10%
OSHA PEL:0.05 MG/M3
ACGIH TLV:0.15 MG/M3 DUST
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CHROMIUM; (CHROMIUM COMPOUNDS) (SARA III) (CAS# & EXPOSURE
LIMITS ARE FOR CHROMIUM METAL)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 5%
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:LEAD MOLYBDATE
CAS:10190-55-3
Fraction by Wt: 0-5%
OSHA PEL:10 MG/M3 (AS MO)
ACGIH TLV:10 MG/M3 (AS MO)
Ingred Name:COPPER; (COPPER COMPOUNDS)(SARA III) (CAS# & EXPOSURE
LIMITS ARE FOR COPPER DUSTS & MISTS)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 0-2%
OSHA PEL:0.1MG/M3 FUME;1 DUST
ACGIH TLV:0.2MG/M3 FUME;1 DUST
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SUPP DATA: ANIMAL STUDIES CLEARLY DEMONSTRATED DOSE-RELATED
ADVERSE EFFECTS ON CNS, HEMATOPOIETIC TISS, BLOOD, (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: KIDNEYS & LIVER, ASSOCIATED W/ADMINISTRATION OF
ETHYLENE GLYCOL MONOBUTYL ETHER ACETATE (EGBEA). (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: (EXTRACTED FROM DHHS (NIOSH) PUBLICATION NO.
90-118) .
RTECS #:9999999ZZ
Ingred Name:HYGIENE PRACT: CLOTHING TO PREVENT PROLONGED SKIN CONTACT.
RTECS #:9999999ZZ
Ingred Name:ACETIC ACID ETHENYL ESTER, POLYMER WITH CHLOROETHENE &
ETHENOL
CAS:25086-48-0
Fraction by Wt: 5-20%
Ingred Name:ETHANOL, 2-PROPOXY; (2-PROPOXYETHANOL). VP: 2.9 @ 25C.
CAS:2807-30-9
RTECS #:KM2800000
Fraction by Wt: 30%
Ingred Name:CYCLOHEXANONE; (CYCLOHEXYL KETONE)(SARA III). VP: 2 @
20C.
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: 15%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHANOL, 2-(2-ETHOXYETHOXY)-,ACETATE; (DIETHYLENE GLYCOL
ETHYL ETHER ACETATE. VP: NEGLIGIBLE.)
CAS:112-15-2
RTECS #:KK8925000
Fraction by Wt: 5%
Ingred Name:2-BUTOXYETHANOL ACETATE; (ETHYLENE GLYCOL MONOBUTYL ETHER
ACETATE). VP: 0.26 @ 20C.
CAS:112-07-2
RTECS #:KJ8925000
Fraction by Wt: 5%
Ingred Name:MIXTURE (N-BUTYL METHYL METHACRYLATE)
Fraction by Wt: 5-20%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: CONT W/LIQ, ITS VAPS/MISTS
MAY CAUSE BURNING/TEARING/REDNESS/EYE DMG. SKIN: CONT MAY CAUSE
IRRIT/ALLERGIC RXN. THIS MATL MAY BE ABSORBED THRU SKIN. INHAL: MAY
CAUSE RESP TRACT IRRIT/NERVS SYS DISORDERS SUCH AS
HDACH/DIZZ/FATG. INGEST: MAY CAUSE GI TRACT IRRIT & SIGNS OF NERVS
SYS DEPRESS. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:LEAD COMPOUND: GROUP 2B (IARC), CHROMIUM
AND CERTAIN CHROMIUM COMPOUNDS: GROUP 1 (NTP/IARC).
Effects of Overexposure:HLTH HAZ: CHRONIC: RPTD/PRLNG OVEREXP BY
INHAL/SKIN ABSORPTION/INGEST MAY CAUSE DELAYED DAMAGE TO
BLOOD/KIDNEYS. RPTD/PRLNG OVEREXP TO LEAD BY INGEST MAY CAUSE
METALLIC TASTE IN MOUTH/NAUS/DIGESTIVE D ISORDERS/ABDOM CRAMPS &
INSOMNIA AS WELL AS BLOOD/NERVOUS/URINARY & REPRODUCTIVE DISORDERS
& BIRTH DEFECTS.(SUPP DATA)
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN OR
LUNG DISORDERS MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THIS
MATERIAL.
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & WATER, CONTACT MD IF IRRITATION PERSISTS.
EYES: FLUSH WELL W/RUNNING WATER FOR A MINIMUM OF 15 MINUTES,
CONTACT MD IF IRRITATION PERSISTS. INHAL: REMOVE TO FRESH AIR,
RESTORE BREAT HING, CONTACT MD. INGEST: CONTACT MD ORPOISON CONTROL
CENTER IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:116F,47C
Lower Limits:0.5%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . WATER MAY BE INEFFECTIVE BUT MAY BE USED TO
COOL CONTAINERS.
Unusual Fire/Explosion Hazard:CLASS II COMBUSTIBLE LIQUID. ISOLATE FROM
HEAT, ELECTRICAL EQUIPMENT, SPARKS, AND OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE
AREA. AVOID BREATHING VAPORS. CONTAIN RELEASE AND REMOVE WITH INERT
ABSORBENT. AVOID CONTACT. USE NON-SPARKING TOOLS TO PLACE MATERIAL
IN APPROPRIATE CONTAINE R FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS IN COOL,
DRY, WELL VENTILATED AREA AWAY FROM SOURCES OF IGNITION. KEEP
CONTAINERS CLOSED WHEN NOT IN USE.
Other Precautions:AVOID PROLONGED/REPEATED OVEREXPOSURE TO THIS
PRODUCT. EMPTY CONTAINERS SHOULD BE DISPOSED OF IN AN
ENVIRONMENTALLY SAFE MANNER IN ACCORDANCE W/APPLICABLE REGULATIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VAPOR CONCENTRATION EXCEEDS TLV, USE
NIOSH/MSHA APPROVED RESPIRATOR WITH ORGANIC CHEMICAL CARTRIDGE.
CONTACT A REPUTABLE SAFETY SUPPLY COMPANY FOR THE APPROPRIATE
RESPIRATOR.
Ventilation:AS REQUIRED TO KEEP VAPOR CONCENTRATION BELOW TLV.
Other Protective Equipment:SOLVENT RESISTANT APRONS & AVAILABILITY OF
AN EYEWASH ARE RECOMMENDED.
Work Hygienic Practices:SMOKE IN DESIGNATED AREAS ONLY. WASH W/SOAP &
WATER BEFORE EATING/SMKNG/USING TOILET FACILITIES. REMOVE CONTAMD
(ING 15)
Supplemental Safety and Health
EFTS OF OVEREXP: "CHROMIUM AND CERTAIN CHROMIUM COMPOUNDS" IS INCLUDED
IN NTP/IARC LISTS OF CARCINOGENS. RPTS HAV ASSOC RPTD/PRLNG OCCUP
OVEREXP TO SOLV W/PERM BRAIN/NERVS SYS DMG. INTENTIONAL MISUSE BY
DELIB CONC/INHAL CONTENTS MAY BE HARMFUL/FATAL. CYCLOHEXANONE HAS
CAUSED LIVER/KIDNEY DMG IN ANIMAL TEST. (ING 12)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:9.9
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:60
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
OTHER NOXIOUS GASES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL,
COUNTY, STATE, AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TT-P-320,ALUMINUM PASTE,STANDARD
CAGE:78901
CAGE:78901
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 65%
OSHA PEL:15MG/M3 DUST/5 FUME
ACGIH TLV:10MG/M3 DUST; 9192
Ingred Name:NAPHTHA (PETROLEUM SPIRITS OR BENZIN)
CAS:8030-30-6
RTECS #:SE7555000
Fraction by Wt: 35%
OSHA PEL:100 PPM
===================== Hazards Identification =====================
Effects of Overexposure:ANESTHETIC-HEADACHE, NAUSEA, UNCONSSCIOUSNESS
======================= First Aid Measures =======================
First Aid:INHALATION:IMMEDIATELY REMOVE TO FRESH AIR. CALLMD. GIVE
ART.RESP. IF NECESSARY.SKIN:REMOVE CONTAMINATED CLOTHING.WASH
THOROUGHLY W/PLENTY OF WATER. CALL MD IMMEDIATELY. EYE:IMMEDIATELY
FLUSH W/WATER FOR AT LEAST 15 MINS. CALL MD.
===================== Fire Fighting Measures =====================
Flash Point:104F TCC
Lower Limits:0.9
Upper Limits:6.0
Extinguishing Media:DRY POWDER, CO*2, FOAM
Fire Fighting Procedures:STANDARD FIRE FIGHTING EQUIPMENT
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP OUT OF SEWERS.DIKE SPILLAGE AREAS AS SOON
AS POSSIBLE.UTILIZE SAND OR EARTH. SHUT OFF VALVES & PUMPS
IMMEDIATELY
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS, OPEN
FLAMES AND WATER. KEEP CONTANERS CLOSED.USE ONLY W/ADEQUATE
VENTILATION.USE NON-FERROUS TYPE TOOLS
Other Precautions:AVOID PROLONGED OR REPEATED BREATHING OF VAPORS AND
CONTACT W/SKIN. PASTE DRUM LIDS SHOULD BE VENTED PRIOR TO OPENING
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED SELF-CONTAINED SYSTEM
ORGANIC CANNISTER
Ventilation:ADEQUATE VENTILATION
Other Protective Equipment:FACE SHIELDS, APRONS, ARM GUARDS, PROTECTIVE
CREAMS
Supplemental Safety and Health
SPECIFIC GRAVITY & BOILING PT ARE GIVEN FOR SOLVENT.MFG SUGGESTS TLV OF
500 PPM BASED ON SOLVENT.PROD MEETS TT-P-320C,TY 2,CLB
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:307F
Vapor Density:4.70
Spec Gravity:0.794
Evaporation Rate & Reference:0.06 TOLVENE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:PASTE, METALLIC WHITE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:MFG SUGGESTS SATURATED SAND OR EARTH MAY BE
POURED ON DRY SAND, EARTH, OR ASHES AT A SAFE DISTANCE FROM
OCCUPIED AREAS & ALLOWED TO EVAPORATE. DISPOSE IN ACCORDANCE
W/LOCAL, STATE & FED, CODES
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:20804-1394 SMDC SHIELDED MILD DETONATING CORD
Preparer's Name:S SCHOOLFIELD/J KOHRING
CAGE:17610
CAGE:17610
============= Composition/Information on Ingredients =============
Ingred Name:X-CHORD, 2.5 GRAINS/FT, SILVER SHEATH
ACGIH TLV:0.1 MG/CUM
Ingred Name:HEXANITROSTILBENE I
ACGIH TLV:10.0 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION TO THE NOSE,
THROAT & MUCOUS MEMBRANE, ALLERGIC REACTIONS. SKIN: IRRITATION &
ABSORPTION, ALLERGIC REACTIONS. EYES: IRRITATION. INGESTION: TOXIC,
MAY CAUSE DEATH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, NAUSEA, REDNESS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER.
INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:DON'T ATTEMPT TO EXTINGUISH. EVACUATE AREA.
USE SCBA TO CONTAIN RESULTING FIRE.
Unusual Fire/Explosion Hazard:IF EXPOSED TO FIRE, THE UNIT MAY
ACTUATE/EXPLODE.
================== Accidental Release Measures ==================
Spill Release Procedures:CALL LOCAL HAZARDOUS MATERIALS TEAM. REMOVE
IGNITION SOURCES. COVER ANY EXPOSED MATERIAL W/VEGETABLE OIL &
REMOVE FOR APPROVED DISPOSAL. USE FLAME RETARDANT CLOTHING, SAFETY
GLASSES & NON-SPARKING TOO LS.
======================Handling and Storage ======================
Handling and Storage Precautions:ANTI-STATIC ARE TO BE USED FOR STORAGE
& SHIPPING.
Other Precautions:THIS MSDS ISN'T INTENDED TO BE AN ORDNANCE HANDLING
DOCUMENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH APPROVED HEPA RESPIRATOR IF PEL/TLV
IS EXCEEDED.
Ventilation:LOCAL EXHAUST: REQUIRED FOR TEST FIRING.
Other Protective Equipment:FLAME RETARDANT COAT & GROUNDING STRAPS TO
PREVENT ELECTROSTATIC DISCHARGE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:INSOLUBLE
Appearance and Odor:SMDC: SILVER; ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALIS, ACIDS, BRONZE, CORROSIVES & OXIDIZERS.
Stability Condition to Avoid:MECHANICAL SHOCK, STATIC ELECTRICITY,
HEAT, FLAME/SPARKS.
Hazardous Decomposition Products:CO, NITROGEN, NITROUS OXIDES,
HYDROGEN, CARBON, CO2 & WATER.
==================== Disposal Considerations ====================
Waste Disposal Methods:UNFIRED UNITS/WASTE SHOULD BE DISPOSED AS
REACTIVE (D003) & TOXIC (D011) HAZARDOUS WASTE, IAW/FEDERAL, STATE
& LOCAL REGULATIONS. UN-0367.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PWC POLYURETHANE AEROSOL COLORS, PWC 212, GLOSS
CAGE:58977
CAGE:58977
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE (SARA 313) (CERCLA). LD50:(ORAL,RAT) 9750 MG/KG.
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 34%
OSHA PEL:1000 PPM
ACGIH TLV:750 PPM;1000 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETIC ACID, BUTYL ESTER; (N-BUTYL ACETATE) (CERCLA).
LD50:(ORAL,RAT) 13,100 MG/KG.
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 5%
OSHA PEL:150 PPM
ACGIH TLV:150 PPM;200 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENE (SARA 313) (CERCLA). LD50:(ORAL,RAT) 4300 MG/KG.
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 13%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM;150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:STODDARD SOLVENT; (MINERAL SPIRITS)
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: <5%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 15%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT
Ingred Name:PROPANE, 2-METHYL-; (ISOBUTANE)
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: <5%
OSHA PEL:800 PPM (MFR)
ACGIH TLV:800 PPM (MFR)
Ingred Name:BUTANE; (NORMAL BUTANE)
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: 5%
OSHA PEL:800 PPM
ACGIH TLV:800 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION:ANESTHETIC. IRRITATION OF
RESPIRATORY TRACT OR NERVOUS SYSTEM, DEPRESSION-CHARACTERIZED BY
HEADACHE, DIZZINESS, NAUSEA OR POSSIBLE UNCONSCIOUSNESS. SKIN
CONTACT:PRIMARY IRRITATION. MAY CAUS E IRRITATION OR BURNING.
PROLONGED OR REPEATED CONTACT MAY CAUSE DERMATITIS-EXERCISE DUE
CARE. EYE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:CONTACT:PRIMARY IRRITATION. SKIN
ABSORPTION:MAY CAUSE IRRITATION OR BURNING SENSATION. INGESTION:NOT
APPLICABLE.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE FROM EXPOSURE &
RESTORE BREATHING, SEEK MEDICAL ATTENTION. SKIN:WASH AFFECTED AREA.
REMOVE CONTAMINATED CLOTHING. SEE MD IF ANY IRRITATION PERSISTS.
EYE S:FLUSH IMMEDIATELY W/WATER FOR AT LEAST 15 MINUTES & TAKE TO
MD.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-15F,-26C
Lower Limits:0.7%
Upper Limits:12.8%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER SPRAY MAY BE INEFT, BUT WATER SPRAY MAY BE USED TO COOL
CNTNRS EXPOS TO HEAT/FIRE TO PVNT PRESS BUILD UP.
Unusual Fire/Explosion Hazard:CLSD CNTNRS MAY EXPLODE DUE TO BUILD UP
OF PRESS FROM EXTREME HEAT/FIRE. AEROSOL SPRAY IS EXTREMELY FLAMM.
SENSITIVITY TO IMPACT:DO NOT PUNCTURE. (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION; SPARKS,
FLAMES, STATIC ELECTRICITY & ELECTRICAL. VENTILATE AREA & SOAK UP
W/INERT ABSORBENT USING NON-SPARKING TYPE TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. DO NOT STORE
OR USE NEAR HEAT, SPARKS OR FLAME. DO NOT GET IN EYES. DO NOT
BREATHE VAPORS. AVOID SKIN CONTACT.
Other Precautions:DO NOT TAKE INTERNALLY. SMOKING WHILE USING THIS
PRODUCT MUST BE STRICTLY PROHIBITED. IN ADDITION TO ALL OTHER
HAZARDS & PRECAUTIONS - DUST FROM SANDING DRY PAINT FILMS SHOULD BE
TREATED AS A NUISANCE DUST W/TLV OF 10 MG/M3.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:OUTDOORS:MFR RECOMMENDS A NIOSH APPROVED
PARTICULATE FILTER TO REMOVE ANY AIRBORNE OVERSPRAY. IN RESTRICTED
AREAS W/POOR VENTILATION & CLOSE TO TLV, A NIOSH APPROVED
RESPIRATOR W/ORGANIC VAPOR CARTRID GE IS RECOMMENDED.
Ventilation:ALL APPLICATION AREAS SHOULD BE ADEQUATELY VENTILATED IN
ORDER TO KEEP INGREDIENTS BELOW THEIR EXPOSURE LIMITS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . IMPERVIOUS APRON TO PREVENT SKIN CONT IS
REC.
Work Hygienic Practices:AVOID PROLONGED OR REPEATED CONTACT. WASH
CONTAMINATED CLOTHING PRIOR TO RE-USE.
Supplemental Safety and Health
EXPLO HAZ:SENSITIVITY TO STATIC DISCHARGE:PRIMARILY VAPORS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:-10F,-23C
Vapor Density:HVR/AIR
Spec Gravity:0.7 (H*2O=1)
VOC Pounds/Gallon:607
VOC Grams/Liter:5.07
Evaporation Rate & Reference:FASTER THAN N-BUAC
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OPAQUE LIQUID; SOLVENT BASED ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:CO, CO*2, HCL & POSSIBLY TRACES OF
PHOSGENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SEC-BUTYL ALCOHOL
Kit Part:=== Responsible Party ===
780-471-4036
780-471-4036
CAGE:Company Name:MATHESON TRI-GAS, INC.
780-471-4036
CAGE:
============= Composition/Information on Ingredients =============
Ingred Name:SEC-BUTYL ALCOHOL
CAS:78-92-2
Fraction by Wt: 100.0%
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:No IARC:NoOSHA:No
Health Hazards Acute and Chronic:INHALATION: SHORT TERM EXPOSURE:
irritation, nausea, vomiting, difficulty breathing, headache,
drowsiness, symptoms of drunkenness LONG TERM EXPOSURE: no
information on significant adverse effects SKIN CONTACT: SHORT TERM
EXPOSURE: mild irritation, symptoms of drunkenness LONG TERM
EXPOSURE: no information on significant adverse effects EYE
CONTACT: SHORT TERM EXPOSURE: irritation (possibly severe), blurred
vision LONG TERM EXPOSURE: same as effects reported in short term
exposure INGESTION: SHORT TERM EXPOSURE: nausea, vomiting,
diarrhea, stomach pain, headache, drowsiness, symptoms of
drunkenness LONG TERM EXPOSURE: liver damage
Medical Cond Aggravated by Exposure:
======================= First Aid Measures =======================
First Aid: INHALATION: If adverse effects occur, remove to
uncontaminated area. Give artificial respiration if not breathing.
Get immediate medical attention. SKIN CONTACT: Wash skin with soap
and water for at least 15 minutes while removing contaminated
clothing and shoes. Get medical attention, if needed. Thoroughly
clean and dry contaminated clothing and shoes before reuse. EYE
CONTACT: Flush eyes with plenty of water for at least 15 minutes.
Then get immediate medical attention. INGESTION: If vomiting
occurs, keep head lower than hips to help prevent aspiration. If
person is unconscious, turn head to side. Get medical attention
immediately. NOTE TO PHYSICIAN: For ingestion, consider gastric
lavage. Consider oxygen.
===================== Fire Fighting Measures =====================
Flash Point:75 F (24 C) (CC)
Autoignition Temp:761 F (405 C)
Lower Limits:1.7% @ 100 C
Upper Limits:9.8% @ 100 C
Extinguishing Media:alcohol resistant foam, carbon dioxide, regular dry
chemical, water, alcohol resistant foam Large fires: Use
alcohol-resistant foam or flood with fine water spray.
Fire Fighting Procedures:Move container from fire area if it can be
done without risk. Cool containers with water spray until well
after the fire is out. Stay away from the ends of tanks. For fires
in cargo or storage area: Cool containers with water from unmanned
hose holder or monitor nozzles until well after fire is out. If
this is impossible then take the following precautions: Keep
unnecessary people away, isolate hazard area and deny entry. Let
the fire burn. Withdraw immediately in case of rising sound from
venting safety device or any discoloration of tanks due to fire.
For tank, rail car or tank truck: Evacuation radius: 800 meters
(1/2 mile). Water may be ineffective.
Unusual Fire/Explosion Hazard:Severe fire hazard. The vapor is heavier
than air. Vapors or gases may ignite at distant ignition sources
and flash back. Vapor/air mixtures are explosive above flash point.
================== Accidental Release Measures ==================
Spill Release Procedures:Avoid heat, flames, sparks and other sources
of ignition. Remove sources of ignition. Stop leak if possible
without personal risk. Reduce vapors with water spray. Small
spills: Absorb with sand or other non-combustible material. Collect
spilled material in appropriate container for disposal. Large
spills: Dike for later disposal. Keep unnecessary people away,
isolate hazard area and deny entry. Stay upwind and keep out of low
areas.
Neutralizing Agent:
======================Handling and Storage ======================
Handling and Storage Precautions:Store and handle in accordance with
all current regulations and standards.
Other Precautions:
============= Exposure Controls/Personal Protection =============
Respiratory Protection:The following respirators and maximum use
concentrations are drawn from NIOSH and/or OSHA. 1000 ppm Any
chemical cartridge respirator with organic vapor cartridge(s). Any
supplied-air respirator. 2000 ppm Any supplied-air respirator. Any
powered, air-purifying respirator with organic vapor cartridge(s).
Any chemical cartridge respirator with a full facepiece and organic
vapor cartridge(s). Any air-purifying respirator with a full
facepiece and an organic vapor canister. Any self-contained
breathing apparatus with a full facepiece. Any supplied-air
respirator with a full facepiece. Escape - Any air-purifying
respirator with a full facepiece and an organic vapor canister. Any
appropriate escape-type, self-contained breathing apparatus. For
Unknown Concentrations or Immediately Dangerous to Life or Health -
Any supplied-air respirator with full facepiece and operated in a
pressure-demand or other positive-pressure mode in combination with
a separate escape supply. Any self-contained breathing apparatus
with a full facepiece.
Ventilation:Ventilation equipment should be explosion-resistant if
explosive concentrations of material are present. Ensure compliance
with applicable exposure limits.
Provide an emergency eye wash fountain and quick drench shower in
the immediate work area.
Other Protective Equipment:Wear appropriate chemical resistant
clothing.
Supplemental Safety and Health
SEC-BUTYL ALCOHOL: 150 ppm (450 mg/m3) OSHA TWA 100 ppm (303 mg/m3)
OSHA TWA (vacated by 58 FR 35338, June 30, 1993) 100 ppm ACGIH TWA
100 ppm (305 mg/m3) NIOSH recommended TWA 10 hour(s) 150 ppm (455
mg/m3) NIOSH recommended STEL
================== Physical/Chemical Properties ==================
Boiling Pt:210 F (99 C)
Melt/Freeze Pt:-173 F (-114 C)
Vapor Pres:12 mmHg @ 20 C
Vapor Density:2.6
Spec Gravity:0.8
pH:Not available
Evaporation Rate & Reference:Not available
Solubility in Water:12.5% @ 20 C
Appearance and Odor:PHYSICAL STATE:liquid COLOR:colorless ODOR:strong
odor
Corrosion Rate:
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:Stable at normal temperatures
and pressure.
Hazardous Decomposition Products:Thermal decomposition products: oxides
of carbon, hydrogen Thermal decomposition products: oxides of
carbon, hydrogen
Conditions to Avoid Polymerization:Will not polymerize.
=================== Toxicological Information===================
Toxicological Information:SEC-BUTYL ALCOHOL: TOXICITY DATA: 2193 mg/kg
oral-rat LD50 LOCAL EFFECTS: Irritant: inhalation, eye ACUTE
TOXICITY LEVEL: Moderately Toxic: ingestion TARGET ORGANS: central
nervous system MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE: eye
disorders, respiratory disorders, skin disorders and allergies
REPRODUCTIVE EFFECTS DATA: Available. ADDITIONAL DATA: Alcohol may
enhance the toxic effects.
===================== Ecological Information =====================
Ecological:ECOTOXICITY DATA: FISH TOXICITY: 3670000 ug/L 96 week(s)
LC50 (Mortality) Fathead minnow (Pimephales promelas) INVERTEBRATE
TOXICITY: 4227000 ug/L 48 hour(s) EC50 (Immobilization) Water flea
(Daphnia magna) ALGAL TOXICITY: 745000 ug/L 48 hour(s) (Population
Growth) Cryptomonad (Chilomonas paramecium) OTHER TOXICITY: 1530000
ug/L 48 hour(s) LC50 (Mortality) Clawed toad (Xenopus laevis)
==================== Disposal Considerations ====================
Waste Disposal Methods:Dispose in accordance with all applicable
regulations.
=================== MSDS Transport Information ===================
Transport Information:U.S. DOT 49 CFR 172.101: PROPER SHIPPING NAME:
Butanols ID NUMBER: UN1120 HAZARD CLASS OR DIVISION: 3 PACKING
GROUP: II LABELING REQUIREMENTS: Flammable liquid
===================== Regulatory Information =====================
SARA Title III Information: SARA TITLE III SECTION 302 EXTREMELY
HAZARDOUS SUBSTANCES (40 CFR 355.30): Not regulated. SARA TITLE
III SECTION 304 EXTREMELY HAZARDOUS SUBSTANCES (40 CFR 355.40): Not
regulated.SARA TITLE III SARA SECTIONS 311/312 HAZARDOUS
CATEGORIES (40 CFR 370.21): ACUTE: Yes CHRONIC: No FIRE: Yes
REACTIVE: No SUDDEN RELEASE: No SARA TITLE III SECTION 313 (40
CFR 372.65): SEC-BUTYL ALCOHOL
Federal Regulatory Information:CERCLA SECTIONS 102a/103 HAZARDOUS
SUBSTANCES (40 CFR 302.4): Not regulated. OSHA PROCESS SAFETY
(29CFR1910.119): Not regulated.
State Regulatory Information: California Proposition 65: Not regulated.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FRICTION MATERIAL,NF-203
CAGE:8H856
CAGE:8H856
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
Fraction by Wt: 45%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9293
Ingred Name:FILLERS,UNSPECIFIED
Fraction by Wt: 30%
Other REC Limits:NONE RECOMMENDED
Ingred Name:BINDERS,TYPE UNSPECIFIED
Fraction by Wt: 25%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE-DUST CAN CAUSE EYES,SKIN &
RESPIRATORY TRACT IRRITATION.CHRONIC-LONG TERM EXPOSURE TO ASBESTOS
CAN CAUSE IRREVERSIBLE ASBESTOSIS,LUNG DISEASE,LUNG
CANCER.ASBESTOSIS IS ASSOCIATED WITH SYMPTOMS O F LABORED
BREATHING,CHEST PAINS,WEAKNESS & CHEST TIGHTNESS.SYMPTOMS ARE NOT
USUALLY MANIFEST UNTIL 15-20 YEARS LATER.
Explanation of Carcinogenicity:ASBESTOS IS REGULATED BY OSHA AS A
CARCINOGEN. SMOKING INCREASES RISK OF CANCER.
Effects of Overexposure:DUST CAN CAUSE EYES, SKIN & RESPIRATORY TRACT
IRRITATION. LONG TERM EXPOSURE TO ASBESTOS CAN CAUSE IRREVERSIBLE
ASBESTOSIS, LUNG DISEASE, LUNG CANCER. ASBESTOSIS IS ASSOCIATED
WITH SYMPTOMS OF LABORED BREATHING, CHEST PAINS, WEAKNESS & CHEST
TIGHTNESS. SYMPTOMS ARE NOT USUALLY MANIFEST UNTIL 15-20 YEARS
AFTER EXPOSURE.
Medical Cond Aggravated by Exposure:RESPIRATORY AILMENTS.
======================= First Aid Measures =======================
First Aid:SEEK MEDICAL ATTENTION IF SYMPTOMS DEVELOP. IN CASE OF EYE
IRRITATION GENTLY RINSE WITH WATER FOR 15 MINUTES WHILE KEEPING
EYELIDS OPEN. SKIN: WASH FREQUENTLY WITH SOAP AND WATER.
INHALATION: REMOVE T O FRESH AIR. INGESTION: UNLIKELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:TOXIC DECOMPOSITION FUMES OR ASBESTOS
FIBERS MAY BE EVOLVED IN A FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:TREAT DUST AS FREE ASBESTOS. DO NOT DRY SWEEP
OR USE COMPRESSED AIR. WET METHOD SHOULD BE USED FOR EXTRACTION OF
DUST AND DEBRIS. HIGH EFFICIENCY PARTICULATE APPARATUS (HEPA)
VACUUMS SHOULD BE USED.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE- AVOID CREATING DUST BY
SANDING OR GRINDING THE PRODUCT.
Other Precautions:USE IN WELL VENTILATED AREA. AVOID BREATHING DUST OR
FIBERS. MINIMIZE CONTACT WITH SKIN. AVOID CONTACT WITH EYES. DO NOT
RAISE DUST. WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING OR
DRINKING. KEEP AWAY FROM REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED HIGH EFFICIENCY FIBERS/FUMES
RESPIRATOR WHEN AIRBORNE FIBER CONCENTRATIONS EXCEED THE PEL.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV. CHECK LOCAL REGULATIONS
FOR EMISSION STANDARDS.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER, WORK
CLOTHING AND APRON AS REQUIRED. DO NOT WEAR CONTACT LENSES
Work Hygienic Practices:DON'T TAKE PROTECTIVE GEAR/CLOTHING HOME IF
EXPOSED TO DUST. DON'T SHAKE. DON'T EAT IN AREA WHERE ASBESTOS/DUST
PRESENT.
Supplemental Safety and Health
THERE ARE TWO MSDS FOR THIS NSN. THE NSN WAS ASSUMED TO BE FOR BOTH.
THE NF-301 IS ASSIGNED PNI A & NF-203 PNI B. TOTAL ITEM RECORD DID
NOT HAVE INFORMATION OTHER THAN LINING, FRICTION.
================== Physical/Chemical Properties ==================
HCC:T6
Spec Gravity:1.36
Appearance and Odor:TAN
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:FIRE AND CREATING DUST
Hazardous Decomposition Products:TOXIC DECOMPOSITION FUMES OR ASBESTOS
FIBERS MAY BE EVOLVED IN A FIRE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE SHOULD BE CONTAINED IN IMPERMEABLE BAGS,
LABELED AND DISPOSED IN ACCORDANCE WITH ALL LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:2934 BIO CIDE
CAGE:0CPM5
CAGE:0CPM5
============= Composition/Information on Ingredients =============
Ingred Name:CARBAMIC ACID, DIMETHYLDITHIO-, POTASSIUM SALT, HYDRATE;
(POTASSIUM DIMETHYL-DITHIOCARBAMATE)
CAS:128-03-0
RTECS #:FA0850000
Fraction by Wt: 5%
Ingred Name:INERT MATERIAL
Fraction by Wt: 95%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DIRECT EYE CONTACT WILL RESULT IN
IRRITATION. PROLONGED SKIN CONTACT WILL RESULT IN IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. IF IRRITATION
PERSISTS, CALL PHYSICIAN. SKIN: FLUSH WITH WATER. INGESTION: DRINK
LARGE VOLUMES OF MILK OR OTHER LIQUID. CALL PHYSICIAN IMMEDIATELY.
INHA LATION: REMOVE FROM EXPOSURE. SUPPORT BREATHING (GIVE
ARTIFICIAL RESPIRATION/OXYGEN) .
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:NONE TO BOILING
Autoignition Temp:Autoignition Temp Text:]
Extinguishing Media:DRY CHEMICAL, FOAM, CO*2.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP PRODUCT. RINSE SOILED AREA WITH WATER
DOWN DRAIN. LARGE SPILLS: STOP LEAK AND COLLECT IN SUITABLE
CONTAINER. RINSE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:ALWAYS STORE UNUSED PORTION IN
ORIGINAL CONTAINER WITH CAP ON. DO NOT STORE MATERIAL IN CONTACT
WITH COPPER ALLOY.
Other Precautions:USE WITH DUE CARE ACCORDING TO LABEL INSTRUCTIONS AND
AVOID TEMPERATURE EXTREMES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:MECHANICAL EXHAUST.
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:NORMAL.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:1.02
Evaporation Rate & Reference:1 (BUAC=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, LIGHT AMBER LIQUID WITH BLAND ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACID WILL CAUSE DECOMPOSITION.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:CARBON DISULFIDE AND DIMETHYLAMINE
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW STATE, LOCAL AND FEDERAL REGULATIONS FOR
DISPOSAL OF LARGE NON-RECLAIMABLE SPILLS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CAT, MIL-P-23377E, TYPE I, CLASS 1; POLYAMIDE
Kit Part:Y
CAGE:33461
CAGE:33461
============= Composition/Information on Ingredients =============
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:150 PPM
ACGIH TLV:150 PPM/200STEL;9394
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:N-BUTYL ALCOHOL (SARA III)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 20%
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 30%
Other REC Limits:500 PPM (STEL)
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 5%
Other REC Limits:150 PPM (STEL)
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 20%
Other REC Limits:300 PPM (STEL)
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:AMINO SILANE ESTER
Fraction by Wt: <1%
Ingred Name:EPOXY RESIN HARDENER
CAS:90-72-2
Fraction by Wt: <1%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:VAPORS ARE IRRITATING TO
EYES,NOSE,& THROAT.INHALATION MAY CAUSE HEADACHES,DIFFICULT
BREATHING & LOSS OF CONSCIOUSNESS. CHRONIC:PROLONGED CONTACT WILL
CAUSE DRYING & CRACKING OF THE SKIN,DUE TODEFATTING ACTION.SKIN
SENSITIZATION,ASTHMA OR OTHER ALLERGIC RESPONSES MAY
DEVELOP.POTENTIAL FOR KIDNEY & LIVER DAMAGE.
Explanation of Carcinogenicity:NONE OF THE CHEMICALS IN THIS PRODUCT IS
LISTED BY IARC, NTP OR OSHA AS A CARCINOGEN.
Effects of
Overexposure:EYES:IRRITATION,TEARING,REDNESS,SWELLING,STINGING
SENSATION. SKIN:IRRITATION,SWELLING,REDNESS,RASH,DRYING AND
DEFATTING WHICH CAN CAUSE CRACKING. INHALATION:IRRITATION OF
RESPIRATORY TRACT & ACUTE NER VOUS SYSTEM
DEPRESSION,HEADACHE,DIZZINESS,STAGGERING
GAIT,CONFUSION,UNCONSCIOUSNESS,COMA. INGESTION:SEE SUPPLEMNTAL DATA
Medical Cond Aggravated by Exposure:ASTHMA AND ANY OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA, AND DERMATITIS.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH WATER FOR AT LEAST 15 MINUTES.SEE DOCTOR.
SKIN:REMOVE CONTAMINATED CLOTHING.WASH SKIN WITH SOAP AND WATER.
INHALATION:REMOVE TO FRESH AIR.GIVE OXYGEN/CPR IF NEEDED.OBTAIN
MEDICAL ATTEN TION. INGESTION:DO NOT INDUCE VOMITING.DO NOT GIVE
ANYTHING TO AN UNCONSCIOUS PERSON.OBTAIN MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:23.0F,-5.0C
Lower Limits:1
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS. CLOSED CONTAINERS
MAY EXPLODE WHEN EXPOSED TO HEAT OF FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL.REMOVE
ALL SOURCES OF IGNITION (FLAME,SPARK SOURCES,HOT
SURFACES).VENTILATE AREA.CONTAIN AND REMOVE WITH INERT ABSORBENT
AND NON-SPARKING TOOLS.
Neutralizing Agent:NONE APPLICABLE FOR THIS MATERIAL
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE, HEAT AND IGNITION SOURCES. KEEP
CONTAINERS CLOSED.
Other Precautions:KEEP CONTAINERS TIGHT AND UPRIGHT TO PREVENT
LEAKAGE.PREVENT PROLONGED BREATHING OF VAPORS OR SPRAY
MISTS.PROLONGED OVEREXPOSURE MAY CAUSE AN ALLERGIC REACTION.AVOID
CONTACT WITH SKIN AND EYES.DO NOT TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A RESPIRATOR THAT IS RECOMMENDED OR APPROVED FOR
USE IN AN ORGANIC VAPOR ENVIRONMENT (AIR PURIFYING OR FRESH AIR
SUPPLIED) IS NECESSARY. OBSERVE OSHA REGULATIONS FOR RESPIRATOR
USE.
Ventilation:SUFFICIENT EXHAUST VENTILATION TO KEEP VAPOR CONCENTRATION
BELOW THE EXPOSURE LIMIT.
Other Protective Equipment:USE LONG SLEEVE AND LONG LEG CLOTHING. EYE
WASH AND SAFETY SHOWER.
Work Hygienic Practices:WASH THROUGHLY AFTER HANDLING AND BEFORE
EATING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
CONTINUED FROM SIGNS & SYMPTOMS OF OVEREXPOSURE-INGESTION:CAN RESULT IN
IRRITATION & POSSIBLE CORROSIVE ACTION IN MOUTH,STOMACH TISSUE &
DIGESTIVE TRACT.VOMIT MAY CAUSE ASPIRATION,RESULTING IN CHEMICA L
PNEUMONITIS. THIS IS NEW FORMULATION FOR PART B OF 2-PART KIT FOR
PART A SEE PNI C,SAME NSN. KEY1:F3.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:=79.4C, 175.F
B.P. Text:175F,79C
Vapor Density:>1
Spec Gravity:0.84
Evaporation Rate & Reference:2.32 (N-BUTYL ACETATE=1)
Appearance and Odor:AMBER LIQUID WITH SOLVENT ODOR.
Percent Volatiles by Volume:82.8
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL, STRONG ACIDS, EPOXY RESINS UNDER UNCONTROLLED
CONDITIONS.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE AND
OXIDES OF NITROGEN.
Conditions to Avoid Polymerization:MANUFACTURER DID NOT SPECIFY, BUT
AVOID HIGH TEMPERATURES.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND
LOCAL LAWS AND REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:A48 N36 DANISH WALNUT OIL STAIN
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA (PETROLEUM SPIRITS OR BENZIN)
CAS:8030-30-6
RTECS #:SE7555000
Fraction by Wt: 75%
OSHA PEL:100 PPM
Ingred Name:MINERAL SPIRITS 140-FLASH (VAPOR PRESSURE = 0.5) (5-10%)
Fraction by Wt: 10%
ACGIH TLV:100 PPM
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <5%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT GIVEN FOR PRODUCT AS A WHOLE
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IN CONFINED AREA VAPORS IN HIGH
CONCENTRATIONS ARE ANESTHETIC. OVEREXPOSURE MAY RESULT IN
LIGHTHEADEDNESS AND STAGGERING GAIT. IRRITANT TO UPPER RESPIRATORY
SYSTEM AND SKIN. REPORTS HAVE ASSOCIATED RE PEATED AND PROLONGED
CONTACT TO SOLVENTS WITH PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:HEADACHE, DIZZINESS, NAUSEA, LOSS OF
COORDINATION; UPPER RESPIRATORY TRACT IRRITATION, SKIN IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP
WARM AND QUIET. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED
CLOTHING. WASH AFFECTED AREA THOROUGHLY WITH SOAP AND WATER. IF
IRRITATION PE RSISTS, GET MEDICAL ATTENTION. EYES: FLUSH WITH LARGE
AMOUNTS OF WATER FOR 15 MINUTES. GET MEDICAL ATTENTION. INGESTION:
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. DO NOT
INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:95.0F,35.0C
Lower Limits:0.9 %
Upper Limits:NOT GIVEN
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE DUE TO THE
BUILD UP OF PRESSURE WHEN EXPOSED TO EXTREME HEAT. DECOMPOSITION
PRODUCTS MAY BE TOXIC. SYMPTOMS MAY APPEAR LATER.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTENTS ARE FLAMMABLE. KEEP AWAY FROM
HEAT, SPARKS, OPEN FLAME. VAPORS WILL ACCUMULATE READILY AND MAY
IGNITE EXPLOSIVELY.
Other Precautions:DURING USE AND UNTIL VAPORS ARE GONE, KEEP AREA
VENTILATED. DO NOT SMOKE. EXTINGUISH ALL FLAMES, PILOT LIGHTS AND
HEATERS. TURN OFF STOVES, ELECTRIC TOOLS AND APPLIANCES, AND OTHER
SOURCES OF IGNITION . AVOID BREATHING VAPOR AND SPRAY MIST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXOSURES BELOW PEL (TLV), USE NIOSH/MSHA APPROVED RESPIRATOR AS PER
CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS AND NIOSH RESPIRATOR
SELECTION.
Ventilation:LOCAL EXHAUST PREFERRABLE. GENERAL EXHAUST ACCEPTABLE IF
EXPOSURE TO MATERIALS CAN BE MAINTAINED BELOW TLV'S.
Other Protective Equipment:EMERGENCY SHOWER AND EYEWASH
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
USE APPROVED BONDING AND GROUNDING PROCEDURES. CONTENTS UNDER PRESSURE.
KEEP CONTAINER CLOSED WHEN NOT INUSE. TRANSFER ONLY TO APPROVED
CONTAINERS WITH COMPLETE AND APPROPRIATE LABELING. DO NOT TAKE I
NTERNALLY. KEEP OUT OF REACH OF CHILDREN. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING AND INHALING MAY BE HARMFUL.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:222-416F
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:NOT GIVEN
Spec Gravity:< 1
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:NOT GIVEN
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER
Percent Volatiles by Volume:85-90%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:EXTREME HEAT, SPARKS, OPEN FLAMES
Hazardous Decomposition Products:CARRBON DIOXIDE, CARBON MONOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:STAFOAM 406 COMBONENT 2 PART B
Kit Part:Y
CAGE:25598
CAGE:25598
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE-2,4-DIISOCYANATE (TDI) (SARA III)
CAS:584-84-9
RTECS #:CZ6300000
Fraction by Wt: 70%
Other REC Limits:NONE SPECIFIED
OSHA PEL:C,0.02 PPM/0.02 STEL
ACGIH TLV:0.005PPM/0.02STEL;93
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:POLYESTER POLYOL
Fraction by Wt: 30%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION- IRRITATION OF
RESPIRATORY TRACT, LUNG IMPAIRMENT, PULMONARY EDEMA. EYES- BURNS,
IRRITATION. SKIN- BURNS, IRRITATION. INGESTION- ABDOMINAL DISTRESS.
CHRONIC: LUNG DAMAGE, POSSIBLE CA NCER.
Explanation of Carcinogenicity:NTP LISTS TOLUENE DIISOCYANATE AS A
POSSIBLE CARCINOGEN, IARC AS A SUSPECTED CARCINOGEN (ANIMAL).
Effects of Overexposure:INHALATION: COUGHING, SHORTNESS OF BREATH,
WEAKNESS, BURNING SENSATION IN LUNGS. EYES: BURNS, TEARING, PAIN.
SKIN: BURNS, BLISTERING, REDNESS, RASH. INGESTION: NAUSEA,
VOMITING.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN AND RESPIRATORY
CONDITIONS MAY BE AGGRAVATED.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESUSCITATE IF NEEDED. GET
IMMEDIATE MEDICAL ATTENTION. EYES: FLUSH WITH LOTS OF WATER UNTIL
ALL MATERIAL GONE. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED
CLOTHI NG. WASH WITH SOAP AND WATER. INGESTION: GIVE PLENTY OF
WATER. DO NOT INDUCE VOMITING! GET IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:260F,127C
Lower Limits:0.9 %
Upper Limits:9.5 %
Extinguishing Media:WATER FOG, CARBON DIOXIDE, OR FOAM
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:WATER CONTAMINATED MATERIAL WILL GENERATE
CARBON DIOXIDE WHICH MAY PRODUCE EXPLOSIVE RUPTURE OF THE
CONTAINERS WHEN EXPOSED TO FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:SHUT OFF/REMOVE SOURCES OF IGNITION. CONTAIN
SPILL. WEAR PROPER PROTECTIVE CLOTHING INCLUDING RESPIRATORY
PROTECTION. ABSORB WITH SAWDUST OR SWEEPING COMPOUND AND PLACE IN A
CLEAN, DRY CONTAINER. DECO NTAMINATE SPILL AREA.
Neutralizing Agent:DECON SOLUTION: 90 % WATER, 8 % AMMONIA, AND 2 %
DETERGENT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN TIGHTLY CLOSED CONTAINERS IN
A DRY, COOL AREA WHERE TEMPERATURE IS 70-90F.
Other Precautions:THIS MATERIAL REACTS WITH WATER AND OTHER MATERIALS;
PRODUCING CARBON DIOXIDE GAS. THIS MAY CAUSE AN EXPLOSIVE RUPTURE
IN TIGHTLY SEALED CONTAINERS. DO NOT RESEAL CONTAINERS IF
CONTAMINATION IS SUSPEC TED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR WITH ORGANIC
VAPOR CARTRIDGE.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER. CLOTHING
TO PREVENT PROLONGED OR REPEATED CONTACT.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CLOTHING/CLEAN FOOTWEAR BEFORE REUSE.
Supplemental Safety and Health
DO NOT EAT, DRINK, OR SMOKE IN WORK AREA. EXPOSURE TO VAPORS OR HOT
MATERIAL CAN BE EXTREMELY DANGEROUS.
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:480F,249C
Vapor Pres:0.01
Vapor Density:6.0
Spec Gravity:1.2
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:APPRECIABLE
Appearance and Odor:LIGHT YELLOW, MEDIUM VISCOSITY LIQUID WITH A STRONG
PUNGENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIS, TERTIARY AMINES, WATER
Stability Condition to Avoid:TEMPERATURES ABOVE 40F FOR EXTENDED
PERIODS OF TIME. SOURCES OF IGNITION.
Hazardous Decomposition Products:ISOCYANATES, HYDROGEN CYANIDE, OXIDES
OF CARBON AND NITROGEN.
Conditions to Avoid Polymerization:WATER AND OTHER PRODUCTS WHICH REACT
WITH ISOCYANATES.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT LOCAL ENVIRONMENTAL MANAGER. DISPOSE OF
IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:848 2598 SPEED CHECK RA DEVELOPER REPLENISHER,PART A
Kit Part:Y
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:SUBSTITUTED STILBENE
CAS:82640-05-9
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM CHLORIDE
CAS:7647-14-5
RTECS #:VZ4725000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 55 - 65%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
Ingred Name:TRIETHANOLAMINE
CAS:102-71-6
RTECS #:KL9275000
Fraction by Wt: 20 - 25%
Other REC Limits:NONE RECOMMENDED
Ingred Name:N,N-DIETHYLHYDROXYLAMINE
CAS:3710-84-7
RTECS #:NC3500000
Fraction by Wt: 10 - 15%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY &
GI TRACTS. ACUTE- CAUSES EYE & SKIN IRRITATION. HARMFUL IF ABSORBED
THROUGH SKIN. MAY BE HARMFUL IF INHALED. HARMFUL IF SWALLOWED. MAY
CAUSE IRRITATION OF GASTRO INTESTINAL TRACT. BASED ON ANIMAL
DATA,TRIETHANOLAMINE MAY CAUSE ADVERSE EFFECTS ON KIDNEY, LIVER.
CHRONIC - UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, TEARING, COUGHING
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS OR IMPAIRED LIVER, KIDNEY OR RESPIRATORY
FUNCTION MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST.
EYE/SKIN:IMMEDIATELY FLUSH WITH WATER FOR 15 MINUTES. HOLD EYELIDS
OPEN. INHALED:MOVE TO FRESH AIR. ORAL:IF CONSCIOUS, INDUCE VOMITING
IMMEDIATELY AS DIRECTE D BY MEDICAL PERSONNEL. CALL A
PHYSICIAN/POISON CONTROL CENTER IMMEDIATELY. NEVER GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:141F (ESTIMATED)
Extinguishing Media:USE WATER SPRAY, CARBON DIOXIDE (CO2), ALCOHOL FOAM
OR DRY CHEMICAL. USE WATER SPRAY TO COOL FIRE EXPOSED CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. HAZARDOUS DECOMPOSITION
PRODUCTS MAY BE FORMED.
Unusual Fire/Explosion Hazard:COMBUSTIBLE LIQUID. CONTAINER MAY
RUPTURE. MAY CAUSE DECOMPOSITION.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES. FLUSH TO SEWER WITH
LARGE AMOUNT OF WATER IF ALLOWED. OTHERWISE, ABSORB SPILL WITH
INERT MATERIAL SUCH AS VERMICULITE, THEN PLACE IN A CONTAINER FOR
CHEMICAL WASTE. CLEAN SURF ACE THOROUGHLY TO REMOVE RESIDUAL
CONTAMINATION.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, VENTILATED PLACE AWAY
FROM IGNITION SOURCES & STRONG OXIDIZING AGENTS. KEEP CONTAINER
TIGHTLY CLOSED.
Other Precautions:DO NOT GET IN EYES, ON SKIN/ON CLOTHING. AVOID
INHALATION OF VAPORS/MIST. FOR INDUSTRIAL AND INSTITUTIONAL USE
ONLY. READ AND FOLLOW ALL LABEL DIRECTIONS AND PRECAUTIONS. WASH
AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCENTRATION IS HIGH, WEAR A
NIOSH-APPROVED ORGANIC VAPOR RESPIRATOR.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES/HR)
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:EYE BATH, WASHING FACILITIES, SAFETY SHOWER
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
KEY1:F4. DIFFERENT FORMULA (SEE A). KIT CONSISTS OF PARTS A, B, C AND
WORKING SOLUTION (PNI B, C, D, W). ECOLOGICAL INFORMATION: A LOW
BIOCHEMICAL OXYGEN DEMAND, A LOW POTENTIAL TO AFFECT AQUATIC ORGA
NISMS. AFTER DILUTION WITH WATER AND WASTE TREATMENT, IT IS NOT
EXPECTED TO CAUSE ADVERSE ENVIRONMENTAL EFFECTS.
================== Physical/Chemical Properties ==================
HCC:B1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:>212F,>100C
Decomp Temp:Decomp Text:>329F,>165C
Vapor Pres:18 @ 68F
Vapor Density:0.6
Spec Gravity:1.06
pH:10.9
Solubility in Water:COMPLETE
Appearance and Odor:YELLOW LIQUID - AMINE ODOR
Percent Volatiles by Volume:60- 65
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:FLAMES, TEMPERATURES ABOVE 65C/149F
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE OR LOCAL REGULATIONS. FLUSH TO SEWER WITH LARGE
AMOUNT OF WATER, IF ALLOWED. SINCE EMPTIED CONTAINERS RETAIN
PRODUCT RESIDUE, FOLLOW L ABEL WARNINGS EVEN AFTER CONTAINER IS
EMPTIED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:D98B01723-01 TELEX
CAGE:0BRX0
CAGE:0BRX0
============= Composition/Information on Ingredients =============
Ingred Name:FREON 113, 1,1,2,-TRICHLORO-1,2,2,-TRIFLUOROETHANE,
TRICHLOROTRIFLUROETHANE
CAS:76-13-1
RTECS #:KJ4000000
Fraction by Wt: 95%
Other REC Limits:1000 PPM
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ozone Depleting Chemical:1
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 5%
Other REC Limits:400 PPM
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NARCOTIC EFFECT, LIVER,
BLOOD, & NERVE DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: NARCOTIC EFFECT, LIVER, BLOOD, &
NERVE DAMAGE.
======================= First Aid Measures =======================
First Aid:SKIN: WIPE OFF MATERIAL & WASH W/SOAP & WATER. EYES: FLUSH
W/WATER FOR 15 MINS. INHALATION: REMOVE TO FRESH AIR. ADMINSTER CPR
IF BREATHING STOPS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Unusual Fire/Explosion Hazard:AUTOIGNITION TEMPERATURE: >750F
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SPILL IN SAWDUST OR OTHER ABSORBENT
MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN TIGHTLY CLOSED CONTAINER IN
COOL, DARK PLACE. DON'T STORE AROUND FOOD. NOT FOR HOUSEHOLE USE.
FOR INDUSTRIAL USE ONLY.
Other Precautions:AVOID INHALATION OF VAPOR. DON'T SMOKE OR DRINK WHILE
USING THIS PRODUCT. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRATORY MASKS FOR ORGANIC CHEMICAL
VAPORS.
Ventilation:LOCAL EXHAUST: RECOMMENDED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:115F
Vapor Pres:334
Vapor Density:1.25
Spec Gravity:1.535
Solubility in Water:5%
Appearance and Odor:CLEAR MOBILE FLUID W/ETHER LIKE ODOR
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:RED HOT SURFACES
Hazardous Decomposition Products:HYDROCHLORIC ACID & PHOSGENE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:QUICKBOND 500 ACTIVATOR
CAGE:61078
CAGE:61078
============= Composition/Information on Ingredients =============
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 89%
OSHA PEL:350 PPM/450 STEL
ACGIH TLV:350 PPM/450STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:ALKYL AMINE
Fraction by Wt: 5%
Ingred Name:SULFONE
Fraction by Wt: 5%
===================== Hazards Identification =====================
Effects of Overexposure:MODERATE TOXIC THROUGH SKIN ABSORB. VAPORS:
HEADACHE,NAUSEA,DIZZY,NARCOSIS.
======================= First Aid Measures =======================
First Aid:EYE/SKIN: FLUSH WITH WATER 15 MINUTES. INHALATION: REMOVE TO
FRESH AIR,CONSULT PHYSICIAN IF SYMPTOMS PERSIST. INGESTION: INDUCE
VOMITING,OBTAIN MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER,FOG,FOAM,DRY CHEMICAL
Fire Fighting Procedures:SELF-CONTAINED RESPIRATORY EQUIPMENT
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH WITH SHOP SOLVENTS
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE WITH REASONABLE CARE,AVOID
BREATHING VAPORS. STORE IN A COOL DRY PLACE.
Other Precautions:NO SMOKING,WELDING,FLAME CUTTING OR BRAZING IN AREA
OF USE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN
Ventilation:LOCAL EXHAUST
Other Protective Equipment:AS NEEDED TO PREVENT SKIN CONTACT.
Supplemental Safety and Health
PART B OF A TWO PART KIT
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:165F/74C
Vapor Pres:100
Vapor Density:4.55
Spec Gravity:1.33
Evaporation Rate & Reference:RAPID
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT YELLOW LIQUID/SHARP ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER - SLOW HYDROLYSIS CAN PRODUCE CORROSIVE ACID.
Stability Condition to Avoid:OPEN FLAMES,HIGH TEMP SOURCES.
Hazardous Decomposition Products:HYDROGEN CHLORIDE,CHLORINE GAS AND
PHOSGENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:BY METHODS CONSISTENT WITH LOCAL,STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: NUXTRA DMR COBALT 6%, 0112055
Cage: 63182
Box: 365
=======================================================
Contractor Summary
=======================================================
Cage: 63182
Box: 365
=======================================================
Ingredients
=======================================================
Cas: 8052-41-3
RTECS #: WJ8925000
% Wt: 62
OSHA PEL: 500 PPM
ACGIH TLV: 100 PPM
------------------------------
Cas: 136-52-7
% Wt: 35
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: WARNING: CAUSES EYE IRRITATION. MAY CAUSE SKIN
IRRITATION. INGESTION CAUSES GASTROINTESTINAL IRRITATION, VOMITING,
DEPRESSION. INHALATION OF CONCENTRATED VAPORS MAY CAUSE RESPIRATORY TRACT
IRRI TATION, HEADACHE, INCOORDINATION, NARCOSIS AND NERVOUS SYSTEM EFFECTS.
ASPIRATION HAZARD IF SWALLOWED. (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: CAN ENTER LUNGS AND CAUSE
DAMAGE. CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHALATION: REMOVE TO FRESH AIR & GIVE ARTIFICIAL
RESPIRATION/OXYGEN IF NEEDED. CALL MD. INGESTION: CALL MD. DO NOT INDUCE
VOMITING. CONTAINS PETROLEUM DISTILLATES. ASPIRATION MAY LEAD TO PNEUMONITIS.
CALL MD. SKIN: WASH WITH SOAP & WATER.EYES: FLUSH WITH WATER FOR AT
LEAST 15 MINUTES. CALL MD IF IRRITATION PERSISTS.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE SOURCES OF IGNITION AND VENTILATE AREA. COVER
WITH INERT, ABSORBENT MATERIAL AND REMOVE TO DISPOSAL CONTAINER. OBSERVE ALL
RELEVANT FEDERAL, STATE, AND LOCAL LAWS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: OBEY RELEVANT LOCAL, STATE, AND FEDERAL LAWS. DO NOT
CONTAMINATE ANY LAKES, STREAMS, PONDS OR UNDERGROUND WATER SUPPLY.
Handling And Storage Precautions: WARNING: COMBUSTIBLE LIQUID. KEEP AWAY FROM
HEAT AND FLAME. MAY BE HARMFUL IF SWALLOWED. AVOID EYE AND SKIN CONTACT.
AVOID BREATHING VAPORS.
Other Precautions: USE WITH ADEQUATE VENTILATION.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: 108F,42C
Lower Limits: 1% @ 77F
Upper Limits: 6% @ 77F
Extinguishing Media: WATER SPRAY, FOAM, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). BURNING WILL PRODUCE TOXIC FUMES.
Unusual Fire/Explosion Hazard: EXPOSURE TO HEAT BUILDS UP PRESSURE IN CLOSED
CONTAINERS. COOL WITH WATER SPRAY.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF EXPOSURE EXCEEDS TLV, USE APPROPRIATE NIOSH/MSHA
APPROVED RESPIRATORY PROTECTIVE EQUIPMENT.
Ventilation: LOCAL EXHAUST AND MECHANICAL VENTILATION RECOMMENDED.
Other Protective Equipment: EMERGENCY EYEWASH & DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >300F,>149C
Vapor Pres: <10 @ 25C
Vapor Density: HVR/AIR
Spec Gravity: 0.87
Evaporation Rate & Reference: SLOWER THAN BUTYL ACETATE
Solubility in Water: NEGLIGIBLE
Appearance and Odor: CLEAR PURPLE LIQUID, WITH PETROLEUM DISTILLATE ODOR
Percent Volatiles by Volume: 65
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: STRONG OXIDANTS.
Hazardous Decomposition Products: BURNING WILL PRODUCE TOXIC FUMES.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: NUXTRA DMR COBALT 6%, 0112055
Cage: 63182
Company Name: HULS AMERICA INC
Street: TURNER PLACE
PO Box: 365
Zipcode: 08855
Label Required IND: Y
Date Of Label Review: 08/15/1995
Status Code: C
Label Date: 08/15/1995
Origination Code: G
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE LIQUID. ACUTE: WARNING: CAUSES EYE
IRRITATION. MAY CAUSE SKIN IRRITATION. INGESTION CAUSES GASTROINTESTINAL
IRRITATION, VOMITING, DEPRESSION. INHALATION OF CONCENTRATED VAPORS MAY CAUSE
RE SPIRATORY TRACT IRRITATION, HEADACHE, INCOORDINATION, NARCOSIS AND NERVOUS
SYSTEM EFFECTS. ASPIRATION HAZARD IF SWALLOWED. CAN ENTER LUNGS AND CAUSE
DAMAGE. CHRONIC: NONE SPECIFIED BY MANUFACTURER.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DTNSRD 2844-1118 COMPONENT B 13-112
Kit Part:Y
Preparer's Name:JIM BOVE
CAGE:NO237
CAGE:9V982
CAGE:NO237
============= Composition/Information on Ingredients =============
Ingred Name:EPOXY RESIN
Fraction by Wt: 28%
Ingred Name:MAGNESIUM SILICATE
CAS:14807-96-6
RTECS #:VV7720000
Fraction by Wt: 18%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3 (RESP DUST)
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 30%
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-ETHOXYETHANOL (EGEE) (SARA III)
CAS:110-80-5
RTECS #:KK8050000
Fraction by Wt: 15%
OSHA PEL:S,200 PPM
ACGIH TLV:S, 5 PPM; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGEST:GI DISTRESS INCL
NAUS,VOMIT&DIARR. ASPIR OF MATL IN LUNGS CAN CAUSE CHEM PNEUMIT
WHICH CAN BE FATAL.INHAL:MAY CAUSE NOSE&THROAT IRRIT.MAY CAUSE
NERVOUS SYS DEPRESS CHARACTERIZEDBY THE FOLLOWING PROGRESSIVE
STEPS:HDCH,DIZZ,NAUS,STAGGERING GAIT,CONFUSION,
UNCONSCIOUSNESS.REPORTS HAVE ASSOC RPTD &(SEE OVEREXPOSURE)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:PRLNG OCCUPATIONAL OVEREXPOS TO SOLV
W/PERM BRAIN & NERVOUS SYS DMG.INTENTIONAL MISUSE BY DELIB CONC &
INHALING CONTENTS MAY BE HARMFUL OR FATAL.EYES:MAY CAUSE SEVERE
IRRIT, REDNESS,TEARING,B LURRED VISION.SKIN:PRLNG OR RPTD CONT CAN
CAUSE MOD IRRIT, DEFATTING,DERM.NIOSH RECOMMENDS THAT 2-EE BE
REGARDED(SUP DAT
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR.RESTORE BRTHING. TREAT
SYMPTOMATICALLY.CONSULT MD.EYES:FLUSH IMMED WITH LARGE AMOUNTS OF
WATER FOR AT LEAST 15 MINUTES.TAKE TO MD FOR MEDICAL
TREATMENT.SKIN:WASH AFFECTED ARE AS WITH SOAP AND WATER.REMOVE
CONTAMINATED CLOTHING.CONSULT MD IF IRRITATION PERSISTS.INGEST:DO
NOT INDUCE VOMITING.CONSULT MD OR POISON CONTROL CENTER IMMED.TREAT
SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point:84.0F,28.9C
Lower Limits:1.4%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION AND PROVIDE
VENTILATION.LARGE SPILLS MAY BE SCOOPED UP WITH NONSPARKING
TOOLS.PROVIDE RESPIRATORY PROTECTION IF REQUIRED.SMALL QUANTITIES
MAY BE PICKED UP WITH ABSORBENT MAT ERIAL.SEE DISPOSAL PRECAUTIONS
BELOW.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CLOSED CONTRS MAY EXPLODE WHEN EXPOSD
TO EXTREME HEAT.STORE AWAY FROM HIGH TEMPS,SPARKS&FLAMES.AVOID SKIN
CONTACT.DO NOT BREATH SPRAY MIST.
Other Precautions:GROUND CONTRS WHILE POURING&LIMIT FREE FALL TO FEW
INCHES TO PVNT STATIC SPARKS.AVOID SPONT COMBUST OF CONTAM
RAGS&OTHER EASILY IGNITABLE ORGANIC ACCUM BY IMMERSION IN
WATER.(SEE SUPP DATA).
============= Exposure Controls/Personal Protection =============
Respiratory Protection:PROVIDE ADEQUATE VENTILATION.IF TLV OF THE
PRODUCT IS EXCEEDED,A NIOSH/MSHA JOINTLY APPROVED SCBA WITH A FULL
FACEPIECE OPERATED IN PRESSURE DEMAND OR OTHER POSITIVE PRESSURE
MODE IS ADVISED.
Ventilation:PROVIDE SUFFICIENT MECHANICAL AND/OR LOCAL EXHAUST
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment:TO PREVENT PROLONGED SKIN CONTACT, WEAR
IMPERVIOUS CLOTHING AND BOOTS. EYEWASH FACILITY, EMERGENCY SHOWER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURE.
Supplemental Safety and Health
OTHER PREC:DO NOT CUT, PUNCTURE OR WELD ON/ NEAR CONTAINER. EMPTIED
CONTAINERS MAY RETAIN HAZARDOUS PROPERTIES. STORE LARGE QUANTITIES
ONLY IN BUILDING DESIGNED TO COMPLY WITH OSHA 1910.106. OVEREXPOS
URE:IN THE WORKPLACE AS HAVING POTENTIAL TO CAUSE ADVERSE
REPRODUCTIVE EFFECTS IN MALE & FEMALE WORKERS .
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:252F,122C
Vapor Pres:SEE INGRED
Vapor Density:>AIR
Spec Gravity:1.1129
Evaporation Rate & Reference:<ETHER
Appearance and Odor:LIQUID PAINT
Percent Volatiles by Volume:64
================= Stability and Reactivity Data =================
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY PRODUCE NOXIOUS FUMES WHEN HEATED
TO DECOMPOSITION, AS IN WELDING. FUMES MAY CONTAIN CO, NITROGEN
OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE IN CLOSED CONTAINERS. SEE OTHER
PRECAUTIONS BELOW. INCINERATE (FIRST OPEN CLOSED CONTAINERS) OR USE
SECURE LANDFILL IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MC-615 ACCELERATOR
Preparer's Name:ERNEST CARTER
CAGE:1DWR5
CAGE:1DWR5
============= Composition/Information on Ingredients =============
Ingred Name:MANGANESE OXIDE
CAS:1313-13-9
RTECS #:OP0350000
= Wt:67.
OSHA PEL:C5 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:TERPHENYL, HYDROGENATED
CAS:61788-32-7
RTECS #:WZ6535000
= Wt:23.
ACGIH TLV:4.9 MG/M3;0.5 PPM
Ingred Name:TERPHENYL
CAS:26140-60-3
RTECS #:WZ6450000
= Wt:2.
OSHA PEL:C9 MG/M3;C1 PPM
ACGIH STEL:C5 MG/M3;C0.53 PPM
Ingred Name:1,3-DIPHENYLGUANIDINE
CAS:102-06-7
RTECS #:MF0875000
= Wt:2.
Ingred Name:MODIFIED PHENOL
= Wt:1.
Ingred Name:SODIUM HYDROXIDE
CAS:1310-73-2
RTECS #:WB4900000
= Wt:2.
OSHA PEL:2 MG/M3
ACGIH STEL:C2 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:EYE CONTACT: CAUSES SEVERE IRRITATION.
CAN CAUSE BURNING SENSATION, TEARING, AND REDNESS. SKIN
CONTACT:MAY CAUSE SLIGHT TO MILD IRRITATION. MAY BE ABSORBED
THROUGH THE SKIN. CAN CAUSE REDNESS, ITCHIN G. AND BURNING
SENSATION. INHALATION (BREATHING): CAN BE IRRITATING TO EYES, NOSE,
AND RESPIRATORY TRACT FOLLOWING PROLONGED EXPOSURE, CAN CAUSE
DIZZINESS, HEADACHES, AND INCOORDINATION. NAUSEA, VOMIT ING, AND
STOMACH UPSET CAN OCCUR. CAN CAUSE WHEEZING, COUGHING, SHORTNESS OF
BREATH, AND TIGHTNESS IN THE CHEST. INGESTION (SWALLOWING):
IRRITATING TO THE MOUTH, THROAT, AND STOMACH, MAY CAUSE NAUSEA,
VOMITING, PAIN, AND STOMACH UPSET.
Effects of Overexposure:EMERGENCY OVERVIEW: CAUSES SEVERE EYE
IRRITATION. INHALATION MAY CAUSE DIZZINESS, HEADACH AND
INCOORDINATION. MAY CAUSE DIGESTIVE TRACT IRRITATION. INGESTION MAY
CAUSE NAUSEA, VOMITING, PAIN, UPSET ST OMACH, DIARRHEA. INHALATION
MAY CAUSE NAUSEA, VOMITING, UPSET STOMACH. MAY CAUSE SKIN
IRRITATION. PROLONGED EXPOSURE MAY CAUSE EYE, NOSE AND RESPIRATORY
TRACT IRRITATION. TARGET ORGANS/CHRONIC EFFECTS : LIVER, KIDNEYS.
NERVOUS SYSTEM. LUNGS AND RESPIRATORY SYSTEM. EYES, SKIN.
Medical Cond Aggravated by Exposure:LIVER, KIDNEYS. LUNGS AND
RESPIRATORY SYSTEM, SKIN.
======================= First Aid Measures =======================
First Aid:EYE CONTACT: IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR
AT LEAST 15 MINUTES. GET MEDICAL ATTENTION. SKIN CONTACT:
IMMEDIATELY FLUSH WITH WATER. REMOVE CONTAMINATED CLOTHING AND
SHOES, GET MEDICALATTENTION. INHALATION (BREATHING): REMOVE TO
FRESH AIR. IF SYMPTOMS DEVELOP, SEEK IMMEDIATE MEDICAL ATTENTION.
INGESTION (SWALLOWING): SEEK MEDICAL ATTENTION. IMMEDIATELY INDUCE
VOMITING, AS DIRECTED BY MEDICAL PERSONNEL.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>93.3C, 200.F
Extinguishing Media:SMALL FIRES: DRY CHEMICAL OR CARBON DIOXIDE. LARGE
FIRES: WATER SPRAY, FOG, OR FOAM. FIRE
Fire Fighting Procedures:FIRE FIGHTERS AND OTHERS WHO MAY BE EXPOSED TO
THE PRODUCTS OS COMBUSTION SHOULD BE EQUIPPED WITHNIOSH-APPROVED.
Unusual Fire/Explosion Hazard:DURING A FIRE, IRRITATING AND HIGHLY
TOXIC GASES MAY BE GENERATED DURING COMBUSTION OR DECOMPOSITION.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATION: ISOLATE HAZARD AREA. KEEP
UNNECESSARY AND UNPROTECTED PERSONNEL FROM ENTERING. CONTAINMENT:
SAFELY STOP DISCHARGE. CONTAIN MATERIAL, AS NECESSARY, WITH A DIKE
OR BARRIER. STOP MATERIAL FR OM CONTAMINATING SOIL, OR FROM
ENTERING SEWERS OR BODIES OF WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, WELL VENTILATED
AREA AWAY FROM HEAT, IGNITION SOURCES, AND DIRECT SUNLIGHT. KEEP
CONTAINERS TIGHTLY CLOSED. TRANSFER: NO SPECIAL PRECAUTIONS ARE
NEEDED. FOLLOW GOOD MANUFACTURING A ND HANDLING PRACTICES.
Other Precautions:THIS CONTAINER CAN BE HAZARDOUS WHEN EMPTY. FOLLOW
LABEL WARNINGS EVEN AFTER CONTAINER IS EMPTIED SINCE EMPTY
CONTAINERS MAY RETAIN PRODUCT RESIDUES. DO NOT RE-USE EMPTY
CONTAINER WITHOUT PROFESSIONAL CLEANING FOR FOOD, CLOTHING, OR
PRODUCTS FOR HUMAN OR ANIMAL CONSUMPTION OR WHERE SKIN CONTACT CAN
OCCUR.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA-APPROVED EQUIPMENT. DETERMINE
THE APPROPRIATE TYPE CONSULTING THE RESPIRATOR MANUFACTURER. HIGH
AIRBORN CONCENTRATIONS MAY NECESSITATE THE USE OF SELF-CONTAINED
BREATHING APPARATUS (SC BA) OR A SUPPLIED AIR RESPIRATOR.
RESPIRATORY PROGRAMS MUST BE IN COMPLIANCE WITH 29 CFR 1910.134.
Ventilation:LOCAL EXHAUST VENTILATION IS RECOMMENDED
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING, ESPECIALLY
BEFORE EATING, DRINKING, AMOKING, AND USING RESTROOM FACILITIES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Pres:0.1
Vapor Density:>1
Spec Gravity:1.9
Evaporation Rate & Reference:<1(BUTYL ACETATE)
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK PASTE PHENOLIC ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, AMPHOTERIC METALS (COPPER, ALUMINUM, ZINC), PEROXIDES; CONTACT
WITH ACID CAN GENERATE HYDROGEN SULFIDE. OXIDIZERS.
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:SMOKE, SOOT, AND TOXIC/IRRITATING
FUMES (I.E. CARBON DIOXIDE, CARBON MONOXIDE, ETC.).
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:MANGANESE OXIDE; EYE, SKIN AND RESPIRATORY
TRACT IRRITANT. CAN CAUSE LIVER AND KIDNEY INJURY.
==================== Disposal Considerations ====================
Waste Disposal Methods:SHOVEL OR VACUUM MATERIAL AND PLACE IN CHEMICAL
WASTE CONTAINERS. DISPOSE OF ACCORDING TO APPLICABLE LOCAL, STATE
AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FP-97A(M) FLUORESCENT PENETRANT, (SEE SUPPL)
Kit Part:Y
CAGE:98733
Contract Num:SP0450-01-M-ZE67
CAGE:98733
============= Composition/Information on Ingredients =============
Ingred Name:HYDROTREATED MIDDLE DISTILLATE
CAS:64742-46-7
RTECS #:JN9379645
Minumum % Wt:40.
Maxumum % Wt:70.
OSHA PEL:5 MG/M3
OSHA STEL:5 MG/M3
ACGIH TLV:10 MG/M3
ACGIH STEL:10 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT: LIQUID MAY CAUSE
IRRITATION, REDNESS, TEARING, AND STINGING OF EYES. SKIN CONTACT:
MAY CAUSE SKIN IRRITATION WITH PROLONGED OR REPEATED CONTACT.
SYMPTOMS MAY INCLUDE REDNESS, BURNING, ANDCRACKING OF SKIN.
SWALLOWING: SMALL AMOUNTS MAY NOT PRODUCE HARMFUL EFFECTS. LARGE
AMOUNTS MAY BE HARMFUL. INHALATION: SMALL AMOUNTS MAY NOT BE
HARMFUL. LARGE AMOUNTS MAY BE HARMFUL.
Explanation of Carcinogenicity:THIS MATERIAL IS NOT KOWN TO CONTAIN ANY
CONSTITUENTS LISTED AS A CARCINOGEN BY THE INTERNATIONAL AGENCY FOR
RESEARCH ON CANCER, THE NATIONAL TOXICOLOGY PROGRAM, OR OSHA.
Effects of Overexposure:EYE CONTACT: IRRITATION, REDNESS, TEARING, AND
STINGING OF EYES. SKIN CONTACT: IRRITATION, REDNESS, BURNING, AND
CRACKING OF SKIN. SWALLOWING AND INHALATION: STOMACH OR INTESTINAL
UPSET (NAUSEA, VOMIT ING, DIARRHEA), IRRITATION (NOSE, THROAT,
AIRWAYS), CENTRAL NERVOUS SYSTEM DEPRESSION (DIZZINESS, DROWSINESS,
FATIGUE, HEADACHE, UNCONSCIOUSNESS).
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH CLEAN WATER FOR 15 MINUTES. HOLD EYELIDS
OPEN. SEEK MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH EXPOSED SKIN AREA WITH SOAP AND WATER. IF SYMPTOMS PERSIST,
SEEK MEDIC AL ATTENTION. LAUNDER CLOTHING AND CLEAN SHOES BEFORE
REUSE. SWALLOWING: CALL A PHYSICIAN. IF DROWSY OR UNCONSCIOUS, DO
NOT GIVE ANYTHING BY MOUTH; PLACE ON LEFT SIDE WITH HEAD DOWN. DO
NOT LEAVE UNAT TENDED. INHALATION:MOVE TO FRESH AIR. IF NOT
BREATHING, GIVE ARTIFICIAL RESPIRATION. IF BREATHING DIFFICULT,
GIVE OXYGEN. GET MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:=93.3C, 200.F
Extinguishing Media:DRY CHEMICAL, WATER FOG, FOAM, OR CARBON DIOXIDE.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE. WATER SPRAY MAY BE
USED TO KEEP FIRE EXPOSED CONTAINERS COOL. WEAR FULL PROTECTIVE
CLOTHING AND NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS WITH
FULL FACE PIECE OPERATE D IN THE PRESSURE DEMAND OR OTHER POSITIVE
PRESSURE MODE.
Unusual Fire/Explosion Hazard:NONE KNOWN. HAZARDOUS PRODUCTS OF
COMBUSTION: MAY FORM CARBON DIOXIDE AND CARBON MONOXIDE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE SOURCES OF IGNITION.
ISOLATE AREA. WEAR PROTECTIVE GEAR, KEEP UNNECESSARY PERSONNEL
AWAY. CONTAIN AND RECOVER LIQUID WHEN POSSIBLE. COLLECT LIQUID IN
AN APPROPRIATE CONTAINER OR ABSORB WITH AN INERT MATERIAL SUCH AS
VERMICULITE, DRY SAND, OR EARTH; DO NOT USE COMBUSTIBLE MATERIALS,
AND PLACE IN A CHEMICAL WASTE CONTAINER. DO NOT FLUSH TO SEWER!
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT AGAINST PHYSICAL DAMAGE. STORE
IN A COOL, DRY, WELL-VENTILATED LOCATION, AWAY FROM AREAS WHERE
FIRE HAZARD MAY EXIST. STORE AND USE IN NO SMOKING AREA.
Other Precautions:EMPTY CONTAINERS MAY CONTAIN RESIDUE LIQUID AND
VAPORS. ANY USE OF THIS PRODUCT IN ELEVATED TEMPERATURE PROCESSING
SHOULD BE THOROUGHLY EVALUATED TO ESTABLISH AND MAINTAIN SAFE
OPERATING CONDITIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE PERSONAL RESPIRATOR (NIOSH APPROVED) IF
EXPOSURE LIMIT IS EXCEEDED.
Ventilation:A SYSTEM OF LOCAL OR GENERAL EXHAUST IS RECOMMENDED TO KEEP
EMPLYOYEE EXPOSURE BELOW AIRBORNE EXPOSURE LIMITS. LOCAL EXHAUST
VENTILATION IS PREFERRED
SHIELD PER OSHA IS ADVISED
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING AND BOOTS. EYE WASH AND
QUICK-DRENCH FACILITIES SHOULD BE NEAR WORK AREA.
Supplemental Safety and Health
PRODUCT CODE: FP-97A(M). GENERAL OR GENERIC ID: AMS-2644 TYPE I, METHOD
B, C, & D, SENSITIVITY LEVEL 4, PENETRANT. THIS ENTRY DESCRIBES THE
PENETRANT, (SERIAL NUMBER CLGXS), PART OF A TWO PART KIT. SE E THIS
SAME NSN,(SERIAL NUMBER CLGXN, PENETRANT EMULSIFIER) FOR SECOND
PART OF KIT.
================== Physical/Chemical Properties ==================
HCC:V5
Boiling Pt:>204.4C, 400.F
B.P. Text:@ 760 MMHG
Spec Gravity:0.969 @ 60F (8.0 LBS/GAL)
Solubility in Water:INSOLUBLE
Appearance and Odor:FLUORESCENT YELLOW-GREEN LIQUID; SLIGHT
HYDROCARBON.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:STABLE UNDER ORDINARY CONDITIONS OF USE
AND STORAGE.
Hazardous Decomposition Products:MAY FORM CARBON DIOXIDE AND CARBON
MONOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:NO DATA AVAILABLE ON PRODUCT.
===================== Ecological Information =====================
Ecological:NO DATA AVAILABLE ON PRODUCT.
==================== Disposal Considerations ====================
Waste Disposal Methods:PROCESSING, USE, OR CONTAMINATION OF THIS
PRODUCT MAY CHANGE THE WASTE MANAGEMENT OPTIONS. STATE AND LOCAL
DISPOSAL REGULATIONS MAY DIFFER FROM FEDERAL DISPOSAL REGULATIONS.
DISPOSE OF CONTAINER AND U NUSED CONTENTS IN ACCORDANCE WITH
FEDERAL, STATE, AND LOCAL REQUIREMENTS.
=================== MSDS Transport Information ===================
Transport Information:DOT INFORMATION: 49 CFR 172.101 NOT REGULATED.
===================== Regulatory Information =====================
SARA Title III Information:SARA 302 COMPONENTS - 40 CFR 355 APPENDIX A:
NONE. SECTION 311/312 HAZARD CLASS - 40 CFR 370.2: IMMEDIATE &
DELAYED. SECTION 311/312 HAZARD CLASS - 40 CFR 370.2: IMMEDIATE,
DELAYED. SARA 313 COMPONEN TS - 40 CFR 372.65: NONE.
Federal Regulatory Information:TSCA: LISTED. CERCLA RQ - 49 CFR
302.4(A): NONE LISTED.
State Regulatory Information:CALIFORNIA PROPOSITION 65 REQUIRES THE
FOLLOWING STATEMENT - PRODUCT MAY CONTAIN DETECTABLE AMOUNTS OF
SUBSTANCES KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CP 730A
CAGE:60218
CAGE:60218
============= Composition/Information on Ingredients =============
Ingred Name:MOLYBDENUM DISULFIDE
CAS:1317-33-5
RTECS #:QA4697000
Fraction by Wt: <1%
OSHA PEL:15 MG/CUM AS (MO)
ACGIH TLV:10 MG/CUM AS (MO)
Ingred Name:DICHLOROMETHANE (METHYLENE CHLORIDE) (SUSPECTED HUMAN
CARCINOGEN BY ACGIH, NTP)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 60%
OSHA PEL:500 PPM
ACGIH TLV:174 MG/CUM (A2)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 16%
Other REC Limits:375 MG/CUM
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROETHANE) (CHLOROTHENE NU),
AEROTHANE TT, CHLOROTHENE
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 4%
Other REC Limits:450 PPM STEL
OSHA PEL:350 PPM
ACGIH TLV:1910 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 1%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: <15%
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: <15%
Other REC Limits:1000 PPM
OSHA PEL:1800 MG/CUM
ACGIH TLV:1000 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION. INGESTION:
HEADACHE, BREATHING DIFFICULTY, METHEMOGLOBINEMIA, NAUSEA,
VOMITING, & ABDOMINAL PAIN. INHALATION: IRRITATION TO RESPIRATORY
SYSTEM, HEADACHE, BREATHING DIFFICULTY, M ETHEMOGLOBINEMIA, NAUSEA,
VOMITING, & ABDOMINAL PAIN.
Explanation of Carcinogenicity:METHYLENE CHLORIDE IS A SUSPECTED A2
HUMAN CARCINOGEN BY ACGIH.
Effects of Overexposure:EYES/SKIN: IRRITATION. INGESTION: HEADACHE,
BREATHING DIFFICULTY, METHEMOGLOBINEMIA, NAUSEA, VOMITING, &
ABDOMINAL PAIN. INHALATION: IRRITATION TO RESPIRATORY SYSTEM,
HEADACHE, BREATHING DIFFICULTY, M ETHEMOGLOBINEMIA, NAUSEA,
VOMITING, & ABDOMINAL PAIN.
Medical Cond Aggravated by Exposure:EYE, SKIN, & RESPIRATORY DISORDERS
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH THOROUGHLY W/WATER FOR 15 MINS.
INGESTION: DON'T INDUCE VOMITING. KEEP VICTIM WARM & QUIET. SKIN:
IMMEDIATELY WASH THOROUGHLY W/SOAP & WATER. INHALATION: REMOVE TO
FRESH AIR. P ROVIDE OXYGEN IF NECESSARY. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRATION. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-40F
Lower Limits:1.8%
Upper Limits:12%
Extinguishing Media:WATER FOG, CO2, DRY CHEMICAL, FOAM, EARTH, OR SAND
Unusual Fire/Explosion Hazard:AT TEMPERATURES >130F, CONTAINERS MAY
VENT, RUPTURE, OR BURST.
================== Accidental Release Measures ==================
Spill Release Procedures:PROVIDE ADEQUATE VENTILATION. WORKMEN SHOULD
BE PROVIDED W/FRESH AIR MASKS OR SENT TO FRESH AIR. SOAK UP W/AN
ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE AT TEMPERATURES >120F.
DON'T USE NEAR SPARKS, OPEN FLAMES, OR EXCESSIVE HEAT. USE
W/ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN CONFINED AREA, USE EITHER
ATMOSPHERE-SUPPLYING RESPIRATOR OR AN AIR-PURIFYING CANNISTER MASK.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:CHEMICALLY RESISTANT
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:-40 TO 284F
Vapor Pres:2740
Vapor Density:4
Spec Gravity:1.0
Evaporation Rate & Reference:(BU AC = 1): 6
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRAY W/SOLVENT ODOR.
Percent Volatiles by Volume:99%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS
Stability Condition to Avoid:TEMPERATURES >120F, SPARKS, OPEN FLAMES,
OR EXCESSIVE HEAT
Hazardous Decomposition Products:CO, CO2, & SULFUR OXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:569 ULANO SCREEN EMULSION PURPLE
CAGE:ULANO
CAGE:53176
CAGE:ULANO
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS FOR INGREDIENTS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: RINSE DOWN DRAIN. LARGE: ABSORB ONTO
SOLID MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:AFTER SENSITIZING, EXPOSURE TO LIGHT
WILL CAUSE THICKING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:NONE
Other Protective Equipment:NONE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F
Spec Gravity:1.05-1.08
Evaporation Rate & Reference:(WATER = 1): 1
Solubility in Water:DILUTABLE
Appearance and Odor:COLORED VISCIOUS LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:LIGHT
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:HAFNIUM BORIDE
CAGE:8G901
CAGE:8G901
============= Composition/Information on Ingredients =============
Ingred Name:HAFNIUM
CAS:7440-58-6
RTECS #:MG4600000
Fraction by Wt: 89.2%
OSHA PEL:0.5 MG/CUM
ACGIH TLV:0.5 MG/CUM
Ingred Name:BORON * 95-3 *
CAS:7440-42-8
RTECS #:ED7350000
Fraction by Wt: 10.8%
ACGIH TLV:10 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: DUST MAY CAUSE MILD
IRRITATION OF THE NOSE & THROAT. SKIN/EYES: IRRITATION DUE TO
ABRASIVE ACTION OF THE DUST.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, COUGHING, WHEEZING, SHORTNESS OF
BREATH.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SKIN: THOROUGHLY WASH AREA
W/MILD SOAP & WATER. EYES: FLUSH W/COPIOUS AMOUNTS OF WATER.
INGESTION: DILUTE W/LARGE AMOUNTS OF WATER. INDUCE VOMITING. OBTAIN
MEDICAL ATT ENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY SAND, LIMESTONE.
Fire Fighting Procedures:FOR POWDER FIRE CONFINED IN A SMALL AREA, USE
A RESPIRATOR APPROVED FOR TOXIC DUST & FUMES. FOR LARGE FIRE, USE
SCBA. (SEE SUPP)
Unusual Fire/Explosion Hazard:DUST MAY PRESENT A FIRE/EXPLOSION HAZARD
UNDER FAVORABLE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION. VENTILATE AREA &
AVOID GENERAL DUST. CLEAN UP USING A VACUUM (W/APPROPRIATE FILTER
TO PREVENT AIRBORNE DUST LEVELS WHICH EXCEED THE PEL/TLV). IF
AIRBORNE DUST IS GENERATED, USE APPROPRIATE NIOSH APPROVED
RESPIRATOR.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP THE CONTAINER CLOSED, WHENEVER
POSSIBLE. DON'T INGEST.
Other Precautions:DON'T SHAKE CLOTHING/OTHER ITEMS TO REMOVE DUST. USE
A VACUUM CLEANER. AVOID DUST INHALATION & DIRECT SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE AN APPROPRIATE NIOSH APPROVED RESPIRATOR IF
AIRBORNE DUST CONCENTRATION EXCEEDS THE APPROPRIATE PEL/TLV.
Ventilation:LOCAL EXHAUST WHICH IS AEQUATE TO LIMIT PERSONNEL EXPOSURE
TO LEVELS WHICH DON'T EXCEED THE TLV.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE
EATING/SMOKING & AT THE END OF THE WORK SHIFT.
Supplemental Safety and Health
MAINTAIN GOOD HOUSEKEEPING PROCEDURES TO PREVENT ACCUMULATION OF DUST.
USE CLEAN UP METHODS WHICH MINIMIZE DUST GENERATION SUCH AS
VACUUMING/WET CLEAN UP.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:37.85F
Spec Gravity:10.5
Solubility in Water:3 G/L
Appearance and Odor:GREY POWDER, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, HYDROGEN GAS
Hazardous Decomposition Products:BORON OXIDE AT HIGH TEMPS. CONTACT
W/ACIDS LIBERATES HYDROGEN GAS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. MAY BE SOLD AS SCRAP FOR RECLAIM/RETURNED TO THE
PRODUCER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:958, SEMI-GLOSS/EGGSHELL/GLOSS LATEX ENAMEL
CAGE:6F266
CAGE:6F266
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA III)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 4%
OSHA PEL:50 PPM, C
ACGIH TLV:50 PPM, C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:PROPIONIC ACID, 2-METHYL-, MONOESTER WITH
2,2,4-TRIMETHYL-1,3-PEMTANEDIOL; (TEXANOL (ESTER ALCOHOL))
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: 2%
Ingred Name:VOLATILE ORGANIC COMPOUNDS:62 GRAMS/LITER
RTECS #:9999999VO
Fraction by Wt: 7.5%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:PROLONGED INHALATION, IN
CONFINED AREAS, MAY LEAD TO MUCOUS MEMBRANE IRRITATION, DIZZINESS,
HEADACHE. SKIN:IRRITATION OF SKIN. EYE:IRRITATION OF EYES.
INGEST:AMOUNTS INGESTED INCINENTAL TO CONSUMER AND INDUSTRIAL
HANDLING ARE NOT LIKELY TO CAUSE INJURY, HOWEVER, INGESTION OF
LARGER AMOUNTS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:COULD CAUSE SERIOUS INJURY.
Medical Cond Aggravated by Exposure:NONE WHEN USED IN ACCORDANCE WITH
SAFE HANDLING INSTRUCTIONS.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. IF RESP SYMPT DEV, SEEK MD ATTN AT
ONCE. SKIN:WASH OFF QUICKLY W/PLENTY OF WATER, THEN SOAP & WATER.
REMOVE & WASH CONTAM CLTHG BEFORE REUSE. EYE:FLUSH IMMED W/LRG AMTS
OF W ATER, ESPECIALLY UNDER LIDS, FOR AT LEAST 15 MIN. OBTAIN EMERG
MD TREATEMENT. INGEST:OBTAIN MD TREATMENT IMMED.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, DRY CHEMICAL, WATER OR WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . WATER MAY BE USED TO COOL AND PROTECT
EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:WILL NOT BURN, CLOSED CONTAINERS MAY
BURST IF EXPOSED TO EXTREME HEAT OR FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:COMPLY WITH ALL APPLICABLE HEALTH AND
ENVIRONMENTAL REGULATIONS. VENTILATE AREA. SPILLS MAY BE COLLECTED
WITH ABSORBENT MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID TEMPERATURES BELOW 40F. KEEP
FROM FREEZING. STORE CONTAINERS WITH LIDS TIGHTLY CLOSED AND
APPROPRIATELY LABELED.
Other Precautions:USE ONLY WITH ADEQUATE VENTILATION. AVOID BREATHING
VAPOR AND SPRAY MIST. AVOID CONTACT WITH SKIN AND EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONNEL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTIALTION, WEAR NIOSH/MSHA APPROVED PROPERLY
FITTED ORGANIC VAPOR/PARTICULATE RESPIRATOR FOR PROTECTION AGAINST
MATERIAL IN INGR EDIENT SECTION.
Ventilation:LOC EXHAUST PREF. GENERAL EXHAUST ACCEPTABLE IF EXPOS TO
MATL IS MAINTAINED BELOW APPLIC LIM.
Other Protective Equipment:EYE WASH AND SAFETY SHOWER.
Work Hygienic Practices:KEEP WORK AREA CLEAN & FREE FROM SPILL & LEAKS.
ALWAYS WASH HANDS THORO W/SOAP & WATER BEFORE HNDLNG
FOOD/DRINK/SMOKING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:23.8 @ 25C
Vapor Density:HVR/AIR
Spec Gravity:1.1-1.3
pH:7-8
Evaporation Rate & Reference:FASTER THAN ETHER
Solubility in Water:INFINITE
Appearance and Odor:THIXOTROPIC LIQUID WITH SLIGHT ODOR; COLOR OF TINT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS AND/OR HYDROFLUORIC ACIDS.
Stability Condition to Avoid:ELEVATED TEMPERATURES, CONTACT WITH
OXIDIZING AGENTS.
Hazardous Decomposition Products:CO, CO*2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:INTERSHIELD PRORECO 508 HAZE GRAY PART A, PRA557
CAGE:028S6
Contract Num:N00406-99-M-9408
CAGE:0JKF4
CAGE:028S6
============= Composition/Information on Ingredients =============
Ingred Name:METHYL N-AMYL KETONE
CAS:110-43-0
RTECS #:MJ5075000
Minumum % Wt:50.
Maxumum % Wt:100.
OSHA PEL:465 MG/M3;100 PPM
ACGIH TLV:233 MG/M3;50 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: CAUSES NOSE AND THROAT
IRRITATION. EYE CONTACT: CAUSES EYE IRRITATION. SKIN CONTACT:
CAUSES SKIN IRRITATION. CAN BE ABSORBED THROUGH THE SKIN. MAY CAUSE
ORGAN DAMAGE. INGESTION: MAY BE FAT AL IF SWALLOWED AND MAY CAUSE
ORGAN DAMAGE.
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:GENERAL: IN ALL CASES OF DOUBT, OR WHEN SYMPTOMS PERSIST,
SEEK MED ATTN. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON. INHAL: REMOVE TO FRESH AIR. IF DISCOMFORT IS PRESENT OR
BREATHING IS ABS ENT GET MED ATTN IMMEDIATELY. EYES: FLUSH
IMMEDIATELY W/PLENTY OF WATER FOR AT LEAST 15 MINUTES UNTIL
IRRITATION SUBSIDES. IF IRRITATION PERSISTS, GET MED ATTN. SKIN:
FLUSH W/LARGE AMOUNTS OF WATER. U SE SOAP IF AVAILABLE. REMOVE
SEVERELY CONTAMINATED CLOTHING (INCLUDING SHOES) AND WASH BEFORE
REUSE. IF IRRITATION PERSISTS, GET MED ATTN. INGEST: IF SWALLOWED,
DO NOT INDUCE VOMITING, KEEP AT REST. G ET PROMPT MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:=37.8C, 100.F
Lower Limits:1%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:OSHA CLASSIFICATION: COMBUST LIQ - CLASS
II. ISOLATE FROM HEAT, SPARKS, ELECTRICAL EQUIP & OPEN FLAME.
CLOSED CNTNRS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT. IN ABSENCE
OF ELECTRICITY, WATER SPRAY (F OGG NOZZ PREFERRED) MAY BE USED TO
COOL CNTNRS. DECOMP & COMBUST PRODS MAY BE TOXIC.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILLED LIQUID WITH SAND OR EARTH. DO
NOT USE COMBUSTIBLE MATERIALS SUCH AS SAWDUST. ABSORB SPILL WITH
AN INERT MATERIAL (EG, DRY SAND OR EARTH), THEN PLACE IN A CHEMICAL
WASTE CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. LOOSEN CLOSURE
CAUTIOUSLY BEFORE OPENING. STORE IN A COOL, WELL VENTILATED PLACE
AWAY FROM INCOMPATIBLE MATERIALS. (SEE STABILITY AND REACTIVITY
SECTION).
Other Precautions:KEEP AWAY FROM HEAT, SPARKS AND FLAMES. PROTECT
MATERIAL FROM SUNLIGHT. GROUND AND BOND CONTAINERS WHEN
TRANSFERRING MATERIALS. EMPTY CONTAINERS MAY RETAIN HAZARDOUS
PROPERTIES. FOLLOW ALL MSDS/LABEL WARNINGS, EVEN AFTER THE
CONTAINER IS EMPTIED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A RESPIRATORY APPROVED BY NIOSH AND IN
ACCORDANCE WITH 29 CFR 1910.134 TO REMOVE PARTICULATES (AND VAPORS
IF THERE IS OVEREXPOSURE TO VAPORS GENERATED DURING THE PROCESSING
OF THIS PRODUCT).
Ventilation:PROVIDE SUFFICIENT VENT, IN VOLUME & PATTERN, TO: A) KEEP
TLV OF HAZ INGREDS BELOW LIMITS SPECIFIED IN INGRED SECTION. B)
REMOVE VOLATILES PRODUCED (SUPDAT)
Other Protective Equipment:EYE WASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . CLOTHING: AS NEEDED, USE BODY PROTECTION TO AVOID
CONTACT WITH PRODUCT.
Supplemental Safety and Health
VENT: DURING WELDING OR CUTTING ON SURFACES COATED W/THIS PRODUCT.
================== Physical/Chemical Properties ==================
Boiling Pt:=126.7C, 260.F
Vapor Density:HVR/AIR
Spec Gravity:1.317
Evaporation Rate & Reference:SLOWER/ETHER
Appearance and Odor:LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO DECOMPOSITION AS IN WELDING. FUMES MAY PRODUCE CARBON
DIOXIDE AND CARBON MONOXIDE.
=================== Toxicological Information===================
Toxicological Information:THERE IS NO DATA AVAILABLE ON THE PRODUCT
ITSELF.
===================== Ecological Information =====================
Ecological:THERE IS NO DATA AVAILABLE ON THE PRODUCT ITSELF.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. DO NOT INCINERATE UNOPENED CONTAINERS.
=================== MSDS Transport Information ===================
Transport Information:DOT (DEPARTMENT OF TRANSPORTATION): PROPER
SHIPPING NAME: PAINT. PACKING GROUP: NOT REGULATED.
===================== Regulatory Information =====================
SARA Title III Information:SARA TITLE III (SUPERFUND AMENDMENTS AND
REAUTHORIZATION ACT): NONE KNOWN UNLESS CHEMICALS ARE SPECIFIED
BELOW.
Federal Regulatory Information:TSCA (TOXIC SUBSTANCE CONTROL ACT):
COMPONENTS OF THIS PRODUCT ARE LISTED ON THE TSCA INVENTORY. CERCLA
(COMPREHENSIVE RESPONSE COMPENSATION AND LIABILITY ACT): WE
RECOMMEND YOU CONTACT LOCAL AUTHORIT IES TO DETERMINE IF THERE MAY
BE OTHER LOCAL REPORTING REQUIREMENTS. OSHA REPORTABLE HAZARDOUS
COMPONENTS (20 CFR 1910.1200): METHYL N-AMYL KETONE. WHMIS
CLASSIFICATION: NOT REGULATED.
State Regulatory Information:CALIFORNIA PROPOSITION 65: WARNING: THIS
PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO
CAUSE CANCER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:N4761 LT GREEN TREE MARKING PAINT
Preparer's Name:MICHAEL LICHATOWICH
CAGE:02388
CAGE:02388
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL SPIRITS (VAPOR PRESSURE 2.0 MM HG @ 20C)
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 47%
Other REC Limits:NONE SPECIFIED
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9293
Ingred Name:ALKYD RESIN
Fraction by Wt: 18%
Other REC Limits:NONE SPECIFIED
Ingred Name:PM ACETATE (VAPOR PRESSURE 3.7 MM @ 20 C)
CAS:108-65-6
RTECS #:AI8925000
Fraction by Wt: 1%
Other REC Limits:NONE SPECIFIED
Ingred Name:COBALT COMPOUNDS (AS CO) (SARA III)
CAS:7440-48-4
RTECS #:GF8750000
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.1 MG/M3;AS CO
ACGIH TLV:0.05 MG/M3;DUST 9293
Ingred Name:MANGANESE (AS MN) (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:BUTYL CELLOSOLVE (VAPOR PRESSURE 0.6 MM HG @ 20C)
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
Ingred Name:PROPRIETARY INGREDIENTS (MANUFACTURER STATES UNIDENTIFIED
INGREDIENTS NOT CONSIDERED HAZARDOUS UNDER FED HZD COMM REGS)
Fraction by Wt: BALANCE
Other REC Limits:NONE SPECIFIED
Ingred Name:VOC: 4.46 LBS/GAL.
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION, LACRIMATION,
REDNESS, BLURRED VISION, VISUAL DISTURBANCES AND EYE BURNS. SKIN:
HARMFUL IF ABSORBED THRU SKIN. CAN BE ABSORBED IN TOXIC AMOUNTS
ESPECIALLY FROM PROLONGED/REPEAT ED EXPOSURES. BREATHING: NASAL &
RESP IRRITATION, CNS DEPRESSION (DIZZINESS, DROWSINESS, WEAKNESS,
FATIGUE, CONFUSION) *
Explanation of Carcinogenicity:NOT LISTED BY NTP, IARC OR OSHA.
Effects of Overexposure:* NAUSEA, HEADACHE, VERTIGO, POSSIBLE
UNCONSCIOUSNESS, EVEN ASPHYXIATION. SWALLOWING: GASTROINTESTINAL
IRRITATION, ABDOMINAL PAIN, NAUSEA, VOMITING, DIARRHEA, BLINDNESS
AND EVEN DEATH. CHRONIC EFFECTS : HEMOLYSIS, HEMOGLOBINURIA. TARGET
ORGANS: SKIN, EYES, RESP SYS, CNS, GI TRACT, LIVER, KIDNEYS,
LYMPHOID SYSTEM, BLOOD.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INHAL: MOVE TO FRESH AIR IMMED. IF BREATHING STOPPED, GIVE
ARTIF RESPIRATION. GET MED AID ASAP. SKIN: WASH W/SOAP & WATER.
EYE: IMMED FLUSH W/WATER 15 MIN, OCCAS LIFT EYELIDS. GET MED AID
IMMED. DON'T WEAR CONTACT LENSES WHEN WORKING W/MAT'L. SWALLOW:
INDUCE VOMIT IMMED BY DRINKING 2 GLASSES WATER & STICK FINGER DOWN
THROAT. NEVER GIVE ANYTHING BY MOUTH TO UNCONSCIOUS PERSON. GET MED
AID IMMED.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:102F,39C
Lower Limits:0.8
Upper Limits:36.0
Extinguishing Media:DRY CHEMICAL, FOAM, CO2.
Fire Fighting Procedures:WEAR SCBA W/FULL FACEPIECE OPERATED IN POS
PRESS MODE & FULL PROTECT CLOTH. MAY USE WTR TO COOL CLSD CNTNR
(PREVENT PRESS BLDUP/AUTOIGNIT/EXPLOS)EXPOSED TO HEAT
Unusual Fire/Explosion Hazard:KEEP CNTNRS CLSD. ISOLATE FROM HEAT,
IGNIT SOURCE. CLSD CNTNRS MAY EXPLODE W/HEAT. APPLIC TO HOT SRFCS
REQ SPCL PRECAUTION. OVEREXPOS TO DECOMP PROD-HEALTH HZD.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. MINIMIZE
BREATHING OF VAPORS & AVOID SKIN CONTACT. ABSORB WITH AN INERT
MATERIAL SUCH AS CLAY, SOIL OR COMMERCIALLY AVAILABLE ABSORBENT.
SHOVEL RECLAIMED LIQUID & ABSOR BENT INTO RECOVERY OR SALVAGE DRUMS
FORDISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID STORAGE IN HIGH TEMPERATURE
AREAS OR NEAR FIRE OR OPEN FLAME. KEEP CONTAINERS CLOSED WHEN NOT
IN USE. AVOID ROUGH HANDLING.
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTY. DO NOT WELD OR FLAME CUT ON EMPTY DRUMS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE (TC-23C-75) FITTED HALF-MASK OR
FULL FACEPIECE RESPIRATOR (NIOSH/MSHA) DURING & AFTER APPLIC UNLESS
AIR MONITORING DEMONSTRATES VAPOR/MIST LEVELS ARE BELOW TLV. FOLLOW
RESPIRATOR MFR' S DIRECTIONS FOR USE.
Ventilation:PROVIDE SUFF VENT (VOL/PATTRN) TO KEEP AIR CONC BELOW
PEL/TLV. REMOVE DECOMP PROD. VENT VAPOR EMIT WHEN BAKING FINISHES.
TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH PROMPTLY WHEN SKIN BECOMES CONTAM. REMOVE
CLOTHING THAT BECOMES WET (FLAMMABILITY HAZARD), WASH BEFORE
REUSE.***
Supplemental Safety and Health
**IF POTENTIAL FOR CONTACT. ***WASH HANDS
BEFORE EATING, SMOKING OR USING RESTROOM.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:146 TO 330F
Vapor Density:> AIR
Spec Gravity:1.083
Viscosity:40-45SZ#2
Evaporation Rate & Reference:SLOWER THAN ETHER.
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID, ODOR OF SOLVENTS.
Percent Volatiles by Volume:69.26
Corrosion Rate:MINIMAL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, CAUSTICS.
Stability Condition to Avoid:HIGH TEMPERATURES, SHOCK FROM DROPPING.
Hazardous Decomposition Products:CAN PRODUCE CARBON MONOXIDE AND/OR
CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL,
STATE AND FEDERAL REGULATIONS. EPA HAZARDOUS WASTE #: D001,
IGNITABLE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ZL-37 ZYGLO PENETRANT
Preparer's Name:BRUCE C. GRAHAM
CAGE:37676
CAGE:37676
============= Composition/Information on Ingredients =============
Ingred Name:DISTILLATES,(PETROLEUM)HYDROTREATED MIDDLE
CAS:64742-46-7
RTECS #:JN9379645
Fraction by Wt: 10.0%
Ingred Name:KEROSENE
CAS:8008-20-6
RTECS #:OA5500000
Fraction by Wt: 05.0%
ACGIH TLV:100MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Health Hazards Acute and Chronic:IRRITATES EYES.
Effects of Overexposure:INHALATION:CAUSES DIZZINESS,DROWSINESS,NAUSEA;
SKIN:LIQUID IRRITATES BY DISSOLVING SKIN OIL; EYES:VAPORS/LIQUID
CAUSES IRRITATION.
Medical Cond Aggravated by Exposure:NOT KNOWN.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR.IF BREATHING IS DIFFICULT,GIVE
OXYGEN; SKIN:REMOVE CONTAMINATED CLOTHES.WASH OFF WITH FLOWING
WATER.USE SOOTHING LOTION.IF IRRITATION PERSISTS,GET MEDICAL ATTN;
EYES:IMM EDIATELY RINSE/FLUSH WITH COPIOUS AMOUNT OF RUNNING
WATER,AND GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F/>93C
Extinguishing Media:CARBON DIOXIDE,FOAM.
Fire Fighting Procedures:KEEP CONTAINERS COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:WHEN INVOLVE IN COMBUSTION,MAY EMIT TOXIC
GASES AT OR ABOVE DECOMPOSITION TEMPERATURE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES.SM QTY:WIPE UP OR MOP
UP BUT DO NOT BREATHE VAPORS.PLACE RAGS IN CLOSED DRUMS; LG
QTY:WEAR PERSONAL SAFETY EQUIPMENTS.DIKE AREA FAR AHEAD.ABSORB
LIQUID WITH COMMERCIAL ABSORBEN T.TRANSFER WASTE MATL IN SALVAGE
TANKS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HEAT SOURCES IN WELL
VENTILATED AREA.AVOID AGAINST PHYSICAL DAMAGE TO CONTAINERS.KEEP
CONTAINERS TIGHTLY CLOSED.
Other Precautions:DO NOT BREATHE VAPORS.DO NOT SMOKE WHILE USING.DO NOT
HEAT ABOVE 130F(54C).AVOID FREQUENT OR PROLONGED SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A RESPIRATOR WITH CHEMICAL CARTRIDGE. IN
CONFINED AREAS,WEAR FULL MASK WITH SEPARATE AIR SUPPLY.
Ventilation:GENERAL VENTILATION TO KEEP BELOW 350PPM LIMIT.
Other Protective Equipment:EITHER USE IN A SPRAY BOOTH OR NEXT TO AN
EXHAUST VENT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.LAUNDER
CONTAMINATED CLOTHES BEFORE RE-USE.
Supplemental Safety and Health
ITEM IS A 2 PARTS KIT.UNDER MIL-I-25135,TYPE I,METHOD D,LEVEL 4,THE
KIT/NSN MAY CONSIST OF ZL-30B OR ZL-37 PENETRANT AND AN
EMULSIFIER(QPL-25135-15) SPECIFIED EITHER ZR-10A OR ZR-10B
EMULSIFIER BE USE D WITH THE ABOVE PENETRANT);KEY1:N1;THIS ENTRY
DESCRIBES ZL-37 PENETRANT;SEE PNI C & D,THIS NSN,FOR EMULSIFIER
DATA.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:410F/210C
Vapor Pres:<0.5MM@100
Vapor Density:>1.0
Spec Gravity:0.96
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GREEN OILY LIQUID
Percent Volatiles by Volume:5%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:HEAT,HIGH TEMPERATURES.
Hazardous Decomposition Products:EMITS OXIDES OF CARBON AND NITROGEN ON
COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR DISPOSE OF AS EPA HAZARDOUS WASTE
D001 (IGNITABLE WASTE),IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL,STATE,LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FLUID THIOGLYCOLLATE MEDIUM 11264
Preparer's Name:SFTY & ENVIRON DEPARTMENT
CAGE:05545
CAGE:05545
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
= Wt:89.9
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:SODIUM CHLORIDE
CAS:7647-14-5
RTECS #:VZ4725000
= Wt:8.5
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:SODIUM SULFITE; (SODIUM SULPHITE)
CAS:7757-83-7
RTECS #:WE2150000
= Wt:1.
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:SODIUM CARBONATE
CAS:497-19-8
RTECS #:VZ4050000
= Wt:.7
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: SKIN: NO IRRITANT EFFECTS.
EYES: NO IRRITATING EFFECTS. SENSITIZATION: NO SENSITIZING EFFECTS
KNOWN. THE PRODUCT IS NOT SUBJECT TO CLASSIFICATION ACCORDING TO
INTERNALLY APPROVED CALCULATION ME THODS FOR PREPARATIONS: WHEN
USED AND HANDLED ACCORDING TO SPECIFICATIONS, THE PRODUCT DOES NOT
HAVE ANY HARMFUL EFFECTS ACCORDING TO MANUFACTURER'S EXPERIENCE AND
THE INFORMATION PROVIDED TO HIM.
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:GENERAL INFORMATION: NO SPECIAL MEASURES REQUIRED.
INHALATION: SUPPLY FRESH AIR. CONSULT DOCTOR IN CASE OF COMPLAINTS.
SKIN: GENERALLY THE PRODUCT DOES NOT IRRITATE THE SKIN. FLUSH WITH
COPIOUS AMOUNT S OF WATER. SEE MD . EYES: RINSE OPENED EYE FOR AT
LEAST 15 MINUTES UNDER RUNNING WATER. INGESTION: IF SYMPTOMS
PERSIST, CONSULT DOCTOR.
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, EXTINGUISHING POWDER OR WATER
SPRAY.
Fire Fighting Procedures:NO SPECIAL MEASURES REQUIRED. WEAR NIOSH
APPROVED SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE
EQUIPMENT . FIGHT LARGER FIRES WITH WATER SPRAY OR
ALCOHOL-RESISTANT FOAM.
Unusual Fire/Explosion Hazard:PRODUCT IS NOT SELF-IGNITING. PRODUCT
DOES NOT PRESENT AN EXPLOSION HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:PERSON-RELATED SAFETY PRECAUTIONS: NOT
REQUIRED. MEASURES FOR ENVIRONMENTAL PROTECTION: NO SPECIAL
MEASURES REQUIRED. MEASURES FOR CLEANING/COLLECTING: NO SPECIAL
MEASURES REQUIRED. ADDITIONAL INFORMA TION: NO DANGEROUS SUBSTANCES
ARE RELEASED.
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL MEASURES REQUIRED FOR SAFE
HANDLING. NO SPECIAL MEASURES REQUIRED FOR PROTECTION AGAINST
EXPLOSIVES AND FIRES. NO SPECIAL REQUIREMENTS TO BE MET BY
STOREROOMS AND RECEPTACLES. NO INFORMATIO N REQUIRED ABOUT STORAGE
IN ONE COMMON STORAGE FACILITY.
Other Precautions:CLASS ACCORDING TO REGULATION ON FLAMMABLE LIQUIDS:
VOID.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED. USE NIOSH APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:THE PRODUCT DOES NOT CONTAIN ANY RELEVANT QUANTITIES OF
MATERIALS WITH CRITICAL VALUES THAT HAVE TO BE MONITORED AT THE
WORKPLACE.
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA .
Work Hygienic Practices:THE USUAL PRECAUTIONARY MEASURES FOR HANDLING
CHEMICALS SHOULD BE FOLLOWED.
Supplemental Safety and Health
PHYSICAL/CHEMICAL PROPERTIES: SOLVENT CONTENT: 0.0%; SOLID CONTENTS:
100.0%.
================== Physical/Chemical Properties ==================
Boiling Pt:>999.C, 1830.2F
Solubility in Water:SOLUBLE
Appearance and Odor:LIGHT BEIGE SOLID WITH CHARACTERISTIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NO DANGEROUS REACTIONS KNOWN.
Hazardous Decomposition Products:NO DECOMPOSITION IF USED ACCORDING TO
SPECIFICATIONS. NO DANGEROUS DECOMPOSITION PRODUCTS KNOWN.
=================== Toxicological Information===================
Toxicological Information:SEE HEALTH HAZARDS SECTION.
===================== Ecological Information =====================
Ecological:GENERAL NOTES: WATER HAZARD CLASS 0 (SELF-ASSESSMENT):
GENERALLY NOT HAZARDOUS FOR WATER.
==================== Disposal Considerations ====================
Waste Disposal Methods:SMALLEST QUANTITIES CAN BE DISPOSED OF WITH
HOUSEHOLD WASTE. DISPOSAL MUST BE MADE ACCORDING TO OFFICIAL
REGULATIONS. DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS .
=================== MSDS Transport Information ===================
Transport Information:MARINE POLLUTANT: NO.
===================== Regulatory Information =====================
Federal Regulatory Information:THIS PRODUCT CONTAINS NO HAZARDOUS
CONSTITUENTS, OR THE CONCENTRATION OF ALL CHEMICAL CONSTITUENTS ARE
BELOW THE REGULATORY THRESHOLD LIMITS DESCRIBED BY OCCUPATIONAL
SAFETY HEALTH ADMINISTRATION HAZA RD COMMUNICATION STANDARD OR
EUROPEAN DIRECTIVE 91/155/EEC, 88/379/EEC, AND 67/546/EEC.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LIQUID HARDENER, 27263
CAGE:DO111
CAGE:DO111
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTANONE, PEROXIDE; (METHYL ETHYL KETONE PEROXIDE) (MEKP)
(CERCLA)
CAS:1338-23-4
RTECS #:EL9450000
Fraction by Wt: 30-35%
OSHA PEL:0.7 PPM, C
ACGIH TLV:0.2 PPM, C
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:HYDROGEN PEROXIDE, 3% (SARA 302) (MFR'S INVALID CAS
#7732-84-1)
CAS:7722-84-1
RTECS #:MX0887000
Fraction by Wt: 0-5%
OSHA PEL:1 PPM
ACGIH TLV:1 PPM
Ingred Name:PHTHALIC ACID, DIMETHYL ESTER; (DIMETHYL PHTHALATE) (SARA
313) (CERCLA)
CAS:131-11-3
RTECS #:TI1575000
Fraction by Wt: 45-50%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:1,3-PENTANEDIOL, 2,2,4-TRIMETHYL-, DIISOBUTYRATE (ESTER);
(2,2,4-TRIMETHYLPENTANEDIOL-1, 3-DIISOBUTYRATE)
CAS:6846-50-0
RTECS #:SA1420000
Fraction by Wt: 15-20%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUNDS: NIL.
RTECS #:9999999VO
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT) 1017 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES:CONTACT CAN CAUSE IMMEDIATE
SEVERE REACTION AND MAY RESULT IN LOSS OF FUNCTIONAL VISION. MAY
CAUSE DELAYED KERATITIS. SKIN:CONTACT CAN CAUSE IRRITATION, (MINOR
ITCHING, BURNING AND/OR REDNE SS), DERMATITIS, DEFATTING. MAY BE
READILY ABSORBED THROUGH SKIN. INHALATION: INHALATION OF VAPORS CAN
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:CAUSE NASAL & RESP IRRIT, DIZZ, WEAK,
FATG, NAUS, HDCH, POSS UNCON &/OR ASPHY. ASPIR OF MATL INTO LUNGS
MAY RSLT IN CHEM PNEUM WHICH CAN BE FATAL. INGEST:CAN CAUSE GI
IRRIT, NAUS, VOMIT, DIAR R. CHRONIC:OVEREXP TO THIS MATL HAS
APPARENTLY BEEN KNOWN TO CAUSE EYE/SKIN DMG & CYTOGENETIC EFTS IN
LAB (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE VICTIM FROM EXPOSURE TO A WELL-VENTILATED AREA.
MAKE THEM COMFORTABLY WARM, BUT NOT HOT. USE OXYGEN OR ARTIFICIAL
RESPIRATION AS REQUIRED. CONSULT MD. SKIN:WASH PROMPTLY W/SOAP &
EXCESS W ATER. EYES:FLUSH PROMPTLY W/EXCESS WATER FOR AT LEAST 15
MINUTES. CONSULT MD. INGEST:DO NOT INDUCE VOMITING. GIVE VICTIM A
GLASS OF WATER. CALL MD IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:180F,82C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . FIGHT LIKE FUEL OIL FIRE. COOL FIRE EXPOSED CONTAINERS
W/WATER SPRAY.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS EXPOSED TO HIGH
TEMPERATURES, SUCH AS FIRE CONDITIONS MAY RUPTURE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE ALL POSSIBLE SOURCES OF
IGNITION. AVOID PROLONGED BREATHING OF VAPOR. CONTAIN SPILL W/INERT
ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE W/ADEQUATE VENTILATION. AVOID
CONTACT W/EYES & SKIN. AVOID BREATHING VAPORS. DO NOT STORE PRODUCT
ABOVE 100F/38C.
Other Precautions:DO NOT FLAME CUT, BRAZE, WELD OR MELD EMPTY
CONTAINERS. KEEP PRODUCT AWAY FROM HEAT, OPEN FLAME & OTHER SOURCES
OF IGNITION. AVOID CONTACT W/STRONG ACIDS, ALKALIES & OXIDIZERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF COMPONENT TLV LIMITS ARE EXCEEDED, USE NIOSH
APPROVED RESPIRATOR TO REMOVE VAPORS. USE A NIOSH APPROVED
AIR-SUPPLIED RESPIRATOR IF NECESSARY.
Ventilation:USE ADEQUATE VENTILATION IN VOLUME & PATTERN TO KEEP
TLV/PEL BELOW RECOMMENDED LEVELS. EXPLOSION-PROOF VENT MAY BE NEC.
Other Protective Equipment:ANSI APPROVED EYE WASH FOUNTAIN & DELUGE
SHOWER . WEAR PROTECTIVE CLOTHING AS REQUIRED TO PREVENT SKIN
CONTACT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
% VOLAT:NEGLIGIBLE (WT). EFTS OF OVEREXP:ANIMALS. CAL PROP 65:TRACE
AMTS OF SOME CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER, BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM MAY BE PRESENT IN
THIS PRODUCT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:DECOMPOSES
Decomp Temp:Decomp Text:>131F,>55C
Vapor Pres:0.1
Vapor Density:HVR/AIR
Spec Gravity:1.17
Evaporation Rate & Reference:SLOWER THAN ETHYL ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR OR RED LIQUID W/FAINT KETONE ODOR.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, ALKALIES, OXIDIZERS.
Stability Condition to Avoid:OPEN FLAMES, SPARKS, HEAT, ELECTRICAL &
STATIC DISCHARGE. STABLE AT AMBIENT TEMPS, BUT MAY DECOMPOSE AT
TEMPS >131F.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE &
CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LEAD ACID BATTERY
CAGE:19209
INC)
CAGE:19209
============= Composition/Information on Ingredients =============
Ingred Name:LEAD (SARA III)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 69%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.05 MG/M3;1910.1025
ACGIH TLV:0.15 MG/M3;DUST 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SULFURIC ACID (SARA III)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 21%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:NON-HAZARDOUS MATERIAL
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ARTICLE(PER 29CFR1910.1600).NOT
APPLICABLE FOR FOR PRODUCT USED IN NORMAL CONDITIONS. BATTERY
CONTAINS ACID ELECTROLYTE COMPLETELY SECURED WITHIN THE BATTERY
CASE.
Effects of Overexposure:NONE
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:BATTERY CONTAINS ACID ELECTROLYTE COMPLETELY SECURED IN
BATTERY CASE. IF BATTERY CASE IS PUNCTURED, COMPLETELY FLUSH ANY
RELEASED MATERIAL FROM SKIN OR EYES WITH WATER.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:MULTI-PURPOSE DRY CHEMICAL OR MULTI-PURPOSE CARBON
DIOXIDE.
Fire Fighting Procedures:COOL BATTERY EXTERIOR TO PREVENT RUPTURE. ACID
MISTS AND VAPORS IN A FIRE ARE TOXIC AND CORROSIVE.
Unusual Fire/Explosion Hazard:HYDROGEN GAS MAY BE PRODUCED AND MAY
EXPLODE IF IGNITED. REMOVE ALL SOURCES OF IGNITION. VENTILATE AREA.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID CONTACT WITH ACID MATERIALS. USE SODA
ASH OR LIME TO NEUTRALIZE. FLUSH WITH LARGE ANOUNTS OF WATER.
Neutralizing Agent:SODA ASH OR LIME.
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL REQUIREMENT SPECIFIED BY
MANUFACTURER.
Other Precautions:READ MANUFACTURERS LITERATURE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NEEDED IN NORMAL SERVICE.
Ventilation:NO SPECIAL REQUIREMENTS.
Other Protective Equipment:NOT NEEDED IN NORMAL SERVICE.
Work Hygienic Practices:NO SPECIAL REQUIREMENTS.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:AVOID SHORTING. USE ONLY APPROVED CHARGING
METHODS.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.NONE
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE IN ACID RESISTANT CONTAINERS. DISPOSE IN
ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS. DO NOT
INCINERATE.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:DITHIOCARB,SX0515,SX0520
CAGE:HO382
CAGE:63612
CAGE:HO382
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM DIETHYLDITHIOCARBAMATE
CAS:20624-25-3
RTECS #:EZ6550000
Fraction by Wt: 100%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 1500 MG/KG ORAL RAT
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:N/K
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHAL:N/K .SKIN:CONTACT CAN CAUSE
IRRITATION.INGEST:N/K .EYES:N/K
Medical Cond Aggravated by Exposure:N/K
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR.GET MD ASSISTANCE.SKIN:WASH WITH
SOAP AND WATER.GET MED ASSISTANCE.EYES:FLUSH THOROUGHLY WITH WATER
FOR AT LEAST 15 MINUTES.GET MED ASSISTANCE.INGEST:GET MD
ASSISTANCE.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY,CARBON DIOXIDE,DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:MAY EMIT TOXIC FUMES OF CARBON
MONOXIDE,CARBON DIOXIDE,NITROGEN COMPOUNDS,AND OXIDES OF SULFUR ON
THERMAL DECOMPOSITION.
================== Accidental Release Measures ==================
Spill Release Procedures:TAKE UP AND CONTAINERIZE FOR PROPER
DISPOSAL.DO NOT FLUSH SPILLS OR RESIDUE INTO SEWER WHICH MAY
CONTAIN ACID
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL PLACE AWAY FROM
ACIDS.DO NOT FLUSH SPILLS OR RESIDUE INTO SEWER WHICH MAY CONTAIN
ACID.
Other Precautions:N/K
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:USE EXHAUST VENTILATION.
Other Protective Equipment:N/K
Work Hygienic Practices:N/K
Supplemental Safety and Health
N/K
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:95C,203F
Decomp Temp:Decomp Text:N/K
Spec Gravity:1.1 (WATER=1)
Solubility in Water:SOLUBLE
Appearance and Odor:WHITE CRYSTALLINE POWDER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS
Stability Condition to Avoid:REACTIONS WITH ACIDS WHICH LIBERATE
POSIONOUS CARBON DISULFIDE.
Hazardous Decomposition Products:CARBON MONOXIDE,CARBON
DISULFIDE,NITROGEN COMPOUNDS,OXIDES OF SULFER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CAPASTIC PART A, (BASE)
Resp. Party Other MSDS Num.:PFS96005
CAGE:89357
CAGE:89357
Contract Num:SP0490-01-M-XC70
CAGE:7Z016
============= Composition/Information on Ingredients =============
Ingred Name:BIS A EPOXY RESIN (BISPHENOL A EPOXY RESIN)
CAS:25068-38-6
RTECS #:CE6880000
Minumum % Wt:20.
Maxumum % Wt:50.
Ingred Name:CALCIUM CARBONATE (LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:CRYSTALLINE SILICA (QUARTZ)
CAS:14808-60-7
RTECS #:VV7330000
Minumum % Wt:20.
Maxumum % Wt:50.
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 FOR RATS > 5,000 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:ROUTES OF ENTRY: EYE
CONTACT/INGESTION/SKIN CONTACT. TARGET ORGANS: EYES/SKIN. HEALTH
HAZARDS: MAY CAUSE MODERATE SKIN INJURY OR AN ALLERGIC SKIN
REACTION WITH CERTAIN INDIVIDUALS.
Explanation of Carcinogenicity:DOES NOT CONTAIN CHEMICALS CONSIDERED TO
BE CARCINOGENIC BY NTP, IARC OR OSHA.
Effects of Overexposure:EYE: MAY CAUSE EYE INJURY WHICH MAY PERSIST FOR
SEVERAL DAYS, CORNEAL INJURY IS UNLIKELY. SKIN: REPEATED EXPOSURE
MAY CAUSE SKIN IRRITATION AND IN SOME CASES, AN ALLERGIC SKIN
REACTION IS POSSIBLE. IN HALATION: VAPORS ARE UNLIKELY DUE TO ITS
PHYSICAL PROPERTIES, EXCEPT WHEN HEATED TO HIGH TEMPERATURES WHICH
CAN GENERATE VAPORS THAT COULD CAUSE HEADACHES, NAUSEA OR
RESPIRATORY IRRITATION IF INHALED.REPEATED AND/OR PROLONGED
EXPOSURE TO LOW CONCENTRATIONS OF VAPORS MAY CAUSE SORE THROAT, EYE
IRRITATION OR SENSITIZATION OF THE RESPIRATORY TRACT AND THE
DEVELOPMENT OF AN ASTHMATIC REACTION TO FURT HER EXPOSURE.
Medical Cond Aggravated by Exposure:ASTHMA, CHRONIC RESPIRATORY
DISEASES, EYE DISEASES, SKIN DISORDERS AND ALLERGIES.
======================= First Aid Measures =======================
First Aid:EYE: IMMEDIATELY FLUSH EYES WITH WATER AT LEAST 15 MINUTES.
OBTAIN MEDICAL ATTENTION IMMEDIATELY. PREFERABLE AN
OPHTHALMOLOGIST. SKIN: IMMEDIATELY FLUSH SKIN AT LEAST 15 MINUTES.
REMOVE CONTAMINATED C LOTHING AND SHOES. OBTAIN MEDICAL ATTENTION.
WASH CLOTHING BEFORE REUSE. DISCARD CONTAMINATED LEATHER APPAREL.
INHALATION: REMOVE PERSON TO FRESH AIR. IF BREATHING STOPPED,
QUALIFIED PERSONNEL ADMINIS TER RESPIRATION. IF BREATHING IS
DIFFICULT, OXYGEN MAY BE GIVEN BY QUALIFIED PERSONNEL. OBTAIN
MEDICAL ATTENTION PROMPTLY. INGESTION: IF PATIENT IS CONSCIOUS,
GIVE 3-4 GLASSES OF MILK OR WATER. DO NOT INDUCE VOMITING. OBTAIN
MEDICAL ATTN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:=218.3C, 425.F
Extinguishing Media:WATER FOG, FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:USE SELF CONTAINED BREATHING APPARATUS, AND
PROPER PROTECTING GEAR WHEN ENTERING CONFINED AREAS WHERE THE
POTENTIAL OF EXPOSURE TO VAPORS OR PRODUCTS OF COMBUSTION EXIST.
Unusual Fire/Explosion Hazard:DECOMPOSITION AND COMBUSTION PRODUCTS MAY
BE TOXIC. CLOSED CONTAINERS MAY RUPTURE WHEN EXPOSED TO HIGH HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
BUTYL RUBBER PROTECTIVE CLOTHING. STOP LEAK IF POSSIBLE. VENTILATE
THE AREA. REDUCE VAPOR SPREADING WITH WATER SPRAY. IF CLEAN UP IS
NOT POSSIBLE, MIX WITH DRY SOIL OR NON-REACTIVE ABSORBENT MATERIAL
AND PLACE IN A CONTAINER, PENDING DISPOSAL. COLLECT RUN-OFF WATER
FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS AND OPEN
FLAME. STORE IN A COOL, DRY PLACE. FLUSH EMPTY CONTAINERS WITH
WATER. KEEP CONTAINERS CLOSED UNTIL READY FOR USE. AVOID BREATHING
FUMES; PROVIDE ADEQUATE VENTILATI ON.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DISPOSABLE CARTRIDGE RESPIRATOR OR POSITIVE
PRESSURE SUPPLIED AIR RESPIRATOR EQUIPPED WITH A FULL FACE PIECE,
DEPENDING UPON THE OPERATION. AS A MATTER OF GOOD INDUSTRIAL
PRACTICE. USE NIOSH APPROVED AIR PURIFYING RESPIRATORS EQUIPPED
WITH PARTICULATE FILTERS DURING ANY SURFACE PREPARATION INVOLVING
SANDBLASTING OR SANDING OF CURED EPOXY SYSTEMS.
Ventilation:PROPER VENTILATION IS NECESSARY. USE LOCAL EXHAUST AND
MECHANICAL SYSTEMS LEADING TO FRESH AIR. USE SUITABLE RESPIRATORY
EQUIPMENT IF INSUFFICIENT VENTILATION.
SITUATIONS.
Other Protective Equipment:USE PROTECTIVE CLOTHING IMPERVIOUS TO THIS
OR FULL BODY SUIT. WILL DEPEND ON THE OPERATION.
Supplemental Safety and Health
CONSISTS OF 2-PARTS; CAPASTIC PART B (HARDNER) AND CAPASTIC PART A
(BASE).
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Density:>1.0
Spec Gravity:1.63
Evaporation Rate & Reference:0.5 X N-BUTYLACETATE
Appearance and Odor:DARK GRAY, PASTE CONSISTENCY. FAINT EPOXY ODOR.
Percent Volatiles by Volume:0.1 WT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONTAMINATIN WITH STRONG ACIDS, BASES, AMINES AND MERCAPTANS CAN CAUSE
POLYMERIZATION.
Stability Condition to Avoid:ELEVATED TEMPERATURES FOR PROLONGED
PERIODS OF TIME.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
NITROGEN OXIDES AND IRRITATING AND TOXIC FUMES AT ELEVATED
TEMPERATURES.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:ORAL RAT LD50 >5,000 MG/KG
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE BY INCINERATION OR LANDFILL, WHERE
PERMITTED BY FEDERAL, STATE AND LOCAL REGULATIONS. DO NOT DISCHARGE
INTO SEWER OR WATERWAYS.
=================== MSDS Transport Information ===================
Transport Information:NOT REGULATED FOR TRANSPORTATION.
===================== Regulatory Information =====================
SARA Title III Information:SEC 312 HAZARD CLASS: IMMEDIATE AND DELAYED
HEALTH HAZARD. INGREDIENTS OF THIS PRODUCT ARE LISTED ON SARA TITLE
III SEC 313 INVENTORY.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ODOR NEUTRALIZER SPRAY, H04060DA
Preparer's Name:HARVEY GRODJESK
CAGE:GO098
CAGE:GO098
CAGE:25718
============= Composition/Information on Ingredients =============
Ingred Name:METHANE, DICHLORO-; (METHYLENE CHLORIDE) (SARA III).
VP:350
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 59.06%
OSHA PEL:500 PPM, 1000, C
ACGIH TLV:50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ISOPROPYL ALCOHOL (SARA III). VP:33
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 3.87%
OSHA PEL:400 PPM; 500 STEL
ACGIH TLV:400 PPM; 500 STEL
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (MINERAL SPIRITS).
VP:2.6
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 11.72%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:DIZZINESS, NAUSEA OR VOMITING.
CHLOROCARBON MATLS HAVE PRDCED SENSIT OF MYOCARDIUM TO EPINEPHRINE
IN LAB ANIMALS & COULD HAVE A SIMILAR EFT IN HUMANS. ADRENOMIMETICS
(E.G. EPINEPHRINE) MAY BE CONTRAIN DICATED EXCEPT FOR
LIFE-SUSTAINING USESIN HUMANS ACUTELY OR CHRONICALLY EXPOSED TO
CHLOROCARBONS .
Explanation of Carcinogenicity:METHYLENE CHLORIDE:IARC MONOGRAPHS,
SUPPLEMENT, VOL 7, PG 194, 1987:GROUP 2B. NTP 6TH ANNUAL RPT ON
CARCINS, (SUP DAT)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE PERSON TO OPEN, VENTILATED AREA. LOOSEN CLOTHING
& KEEP WARM. IF DISTRESS PERSISTS, CALL MD. INGEST: CALL MD
IMMEDIATELY . SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD . EYE
S:IMMEDIATELY FLUSH W/POTABLE WATER FORAT MINIMUM OF 15 MINS. SEEK
ASSISTANCE FROM MD .
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Lower Limits:0.70%
Upper Limits:19%
Extinguishing Media:CARBON DIOXIDE, FOAM OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
& FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE HCL & PHOSGENE . AEROSOL CAN MAY EXPLODE. MAY GENERATE
PHOSGENE GAS.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE. KEEP FROM
OPEN FLAME. USE AS DIRECTED W/ADEQUATE VENTILATION. CONTENTS UNDER
PRESSURE.
Other Precautions:NO SMOKING IN AREA OF USE. DO NOT USE IN GEN VICINITY
OF ARC WELDING, OPEN FLAMES OR HOT SURFACES. HEAT &/OR UV RADIA MAY
CAUSE FORMATION OF HCL &/OR PHOSGENE .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE, IF USED W/ADEQUATE VENTILATION. NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:NONE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLAN OF CARCIN:1991:ANTICIPATED TO BE CARCINOGEN.
================== Physical/Chemical Properties ==================
HCC:T4
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:1.4646
Evaporation Rate & Reference:FASTER/BUTYL ACETATE
Appearance and Odor:SWEET ODOR.
Percent Volatiles by Volume:1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:DO NOT HEAT CONTENTS IN CAN.
Hazardous Decomposition Products:HCL & PHOSGENE . CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT PUNCTURE CAN. DO NOT INCINERATE. DISPOSAL
MUST BE IN ACCORDANCE W/FEDERAL, STATE & LOCAL REGULATIONS .
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:HALON 1301
Preparer's Name:FRC INTERNATIONAL
CAGE:0ETK4
CAGE:0ETK4
============= Composition/Information on Ingredients =============
Ingred Name:BROMOTRIFLUOROMETHANE
CAS:75-63-8
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV: 1000 PPM
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HALON 1301 HAS ANESTHETIC & CARDIAC
EFFECTS IN HUMANS AT CONCENTRATIONS BELOW 10% ARE CONSIDERED SAFE
FOR 0-5 MINUTES EXPOSURES. HALON 1301 IS CLASSIFIED AS GROUP 6
(LEAST TOXIC) IN THE UNDERWRITERS L ABORATORIES CLASSIFICATION OF
COMPARATIVE LIFE HAZARDS OF FIRE EXTINGUISHING AGENTS.
Explanation of Carcinogenicity:NOT A LISTED CARCINOGEN.
Effects of Overexposure:THE ANESTHETIC EFFECTS OF HALON 1301 AT LEVELS
BELOW 10% IS SIMILIAR TO A FEELING OF MILD INTOXICATION. ANESTHETIC
EFFECTS TO CONCENTRATIONS ABOVE 10% (15-20), MAY LEAD TO
UNCONSCIOUSNESS AND POSSIBLY DEATH.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PREEXISTING
DISEASE OF THE CENTRAL NERVOUS OR CARDIOVASCULAR SYSTEM MAY HAVE
INCREASED SUSCEPTIBILITY TO THE TOXICITY OF EXCESSIVE EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALE-REMOVE VICTIM TO FRESH AIR. GIVE SYMPTOMATIC AND
SUPPORTIVE CARE. GET MEDICAL ATTENTION. NOTE: ADRENALINE IS
CONTRAINDICATED IN THE TREATMENT OF OVEREXPOSURE TO HALON 1301.
SKIN-FLUSH SKIN WITH PLENTY OF WATER FOR 15 MIN. EYE-IMMEDIATELY
FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MIN. NOTES TO
PHYSICIAN: CATECHOLAMINE DRUGS, SUCH AS SPINEPHRICE, SHOULD BE USED
WITH CAUTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:HALON 1301 IS A FIRE EXTINGUISHING AGENT.
Fire Fighting Procedures:USE WATER SPRAY OR FOG TO COOL CONTAINERS.
SELF-CONTAINED BREATHING APPARATUS IS REQUIRED IF CYLINDERS RUPTURE
OR RELEASE UNDER FIRE CONDITIONS.
Unusual Fire/Explosion Hazard:CYLINDERS ARE EQUIPPED WITH RELIEF
DEVICES BUT MAY STILL RUPTURE UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:AIR OUT ENCLOSED OR LOW AREAS. REMOVE OPEN
FLAMES. SELF-CONTAINED BREATHING APPARATUS FOR LARGE LEAKS OR
SPILL.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTAINER DAMAGE.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED SELF-CONTAINED BREATHING
APPARATUS IF EXPOSED TO CONCENTRATIONS GREATER THAN 10%.
Ventilation:LOCAL EXHAUST, NORMAL VENTILATION ADEQUATE. MECHANICAL
(GENERAL) VENTILATION, USE IN LOW OR ENCLOSED PLACES.
Other Protective Equipment:NONE.
Work Hygienic Practices:DETERMINE THAT PIPING IS EMPTY BEFORE DOING
MAINTENANCE WORK.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:G3
Boiling Pt:B.P. Text:-72F,-58C
Vapor Pres:435 PSIG
Vapor Density:5.14
Spec Gravity:1.57
pH:7
Evaporation Rate & Reference:>1 (CCL4=1)
Solubility in Water:0.03 WT @ 25C
Appearance and Odor:CLEAR, COLORLESS, LIQUIFIED GAS. SLIGHT ETHERAL
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACTIVE METALS, ALKALI, FIRES OF METAL HYDRIDES, AND MATERIAL CONTAINING
OWN OXYGEN.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:THE PRESENCE OF FLAMES/HOT SURFACES;
HYDROGEN FLUORIDE, HYDROGEN BROMIDE, BROMINE, CARBONYL FLUORIDE,
CARBONYL BROMIDE.
Conditions to Avoid Polymerization:HIGH TEMPERATURES, GOWING METAL
SURFACES, OPEN FLAMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY WITH ALL FEDERAL, STATE AND LOCAL
REGULATIONS. RECLAIM BY RECOVERY MACHINES AND REMOVE TO PERMITTED
WASTE DISPOSAL FACILITY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HYDROGEN PEROXIDE, 3%
Resp. Party Other MSDS Num.:HH 180
CAGE:EO227
CAGE:EO227
Contract Num:MDA414-98-A-0024-0093
CAGE:63759
Contract Num:MDA414-98-A-0024-0094
CAGE:63759
Contract Num:MDA414-98-A-0024-0106
CAGE:63759
Contract Num:MDA414-98-A-0024-0123
CAGE:63759
============= Composition/Information on Ingredients =============
Ingred Name:HYDROGEN PEROXIDE
CAS:7722-84-1
RTECS #:MX0899000
= Wt:3.
OSHA PEL:1.4 MG/M3;1 PPM
ACGIH TLV:1.4 MG/M3;1 PPM
Ingred Name:ACETANILIDE
CAS:103-84-4
RTECS #:AD7350000
= Wt:.05
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
= Wt:97.
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:EYES:MAY CAUSE IRRITATION ON CONTACT.
SKIN:PROLONGED CONTACT WITH SKIN MAY PRODUCE IRRITATION.
INGESTION:MAY BE HARMFUL IF SWALLOWED. EXERCISE APPROPRIATE
PROCEDURES TO MINIMIZE POTENTIAL HAZARDS.
Effects of Overexposure:EYES/SKIN:IRRITATION. INGESTION:HARMFUL
======================= First Aid Measures =======================
First Aid:EYES:FLUSH THOROUGHLY WITH WATER FOR 15 MINUTES,LIFTING UPPER
AND LOWER EYELIDS OCCASIONALLY.GET IMMEDIATE MEDICAL ATTENTION.
SKIN:FLUSH THOROUGHLY WITH WATER,THEN WASH WITH MILD SOAP AND
WATER. INGES TION:IF SWALLOWED, IF CONSCIOUS, GIVE ONE OR TWO
GLASSES OF WATER TO DRINK. CALL A PHYSICIAN. NEVER GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Autoignition Temp:Autoignition Temp Text:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:USE WATER IN LARGE QUANTITIES FOR EXTINGUISHING
SUPPORTING FIRE.
Fire Fighting Procedures:USE WATER IN LARGE AMOUNTS TO FIGHT FIRE IN
WHICH THIS MATERIAL IS INVOLVED. IN FIRE CONDITIONS, WEAR A
NIOSH/APPROVED SELF-CONTAINED BREATHING APPARATUS AND EYE
PROTECTION.
Unusual Fire/Explosion Hazard:HYDROGEN PEROXIDE IS NON-FLAMMABLE, BUT
IT PROVIDES OXYGEN TO FACILITATE OR INITIATE BURNING OF SURROUNDING
COMBUSTIBLES.
================== Accidental Release Measures ==================
Spill Release Procedures:DILUTE WITH WATER TO 1% OR LESS AND FLUSH TO
SEWER WITH COPIOUS AMOUNTS OF WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DARK PLACE. PROTECT
FROM STRONG SUNLIGHT, REDUCING AGENTS AND ORGANICS. CHECK AFTER ONE
YEAR. BEWARE OF BULGING CONTAINERS, WHICH CAN BURST FROM PRESSURE.
KEEP CONTAINER TIGHTLY CLOSE D WHEN NOT IN USE.
Other Precautions:AVOID CONTACT WITH EYES OR PROLONGED CONTACT WITH
SKIN. WASH THOROUGHLY AFTER HANDLING. REMOVE AND WASH CONTAMINATED
CLOTHING. FOR LABORATORY USE ONLY. NOT FOR DRUG, FOOD, OR HOUSEHOLD
USE. KEEP OUT O F REACH OF CHILDREN. DO NOT WEAR CONTACT LENSES
WHEN WORKING WITH CHEMICALS. READ LABEL BEFORE USING .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NEEDED IN NORMAL LABORATORY HANDLING. IF
MISTY CONDITIONS PREVAIL, WORK IN VENTILATION HOOD OR WEAR NIOSH
APPROVED RESPIRATOR.
Ventilation:LOCAL/MECHANICAL:NONE NEEDED. SPECIAL OR OTHER:NO.
Supplemental Safety and Health
WARD'S CATALOG NUMBER: 37W8450
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:=100.C, 212.F
Melt/Freeze Pt:=0.C, 32.F
Vapor Pres:14(WATER)
Vapor Density:0.7(H20)
Spec Gravity:1.00
Evaporation Rate & Reference:>1(ETHER=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID; NO ODOR
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
DO NOT ADD ANYTHING TO THIS CONTAINER-AS VIOLENT REACTION MAY OCCUR.
READILY REACTS WITH REDUCING AGENTS, ORGANIC MATERIALS, DIRT, RUST,
METALS.
Stability Condition to Avoid:STABILITY DECREASED BY STRONG SUNLIGHT,
HEAT, MIXING.
Hazardous Decomposition Products:DECOMPOSES TO WATER AND OXYGEN.
=================== Toxicological Information===================
Toxicological Information:TWA:1PPM; 1.5MG/M3(AIR). STEL:2PPM; 3MG/M3
(AIR). (ACGIH 1980-84). MATERIAL DECREASES IN HAZARD AS H2O2
CONCENTRATION DECREASES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE,TREATMENT,OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE OR LOCAL LAWS.THESE DISPOSAL GUIDE LINES ARE
INTENDED FOR CATALOG-SIZE QUANTITIES ONLY. DILUTE WITH WATER TO 1%
OR LESS AND FLUSH TO SE WER WITH COPIOUS AMOUNTS OF WATER.
=================== MSDS Transport Information ===================
Transport Information:DOT: NON-REGULATED.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HYDROCHLORIC ACID,CONCENTRATED (36-37),A 14
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:HYDROGEN CHLORIDE (HYDROCHLORIC ACID) (SARA III)
CAS:7647-01-0
RTECS #:MW4025000
Fraction by Wt: 35 - 38%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 5 PPM
ACGIH TLV:C 5 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 62 - 65%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LC50 (RAT, INHALATION-1 HR) IS 3124 PPM
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CORROSIVE.ACUTE-ORAL:SEVERE
MOUTH,THROAT,ESOPHAGUS & STOMACH BURNS &
PAIN,NAUSEA,VOMITING,DIARRHEA,THIRST,NECROSIS,FEVER,CHILLS,SHOCK.DE
ATH MAY OCCUR.EYE/SKIN:SEVERE BURNS.INHALE:PULMONARY EDEMA,CIRCU
LATORY FAILURE,RESPIRATORY SYSTEM
DAMAGE,COLLAPSE,COUGHING,DIFFICULT BREATHING.CHRONIC-TEETH
ERROSION,BRONCHITIS.
Effects of Overexposure:DANGER! CAUSES SEVERE BURNS. MAY BE FATAL IF
SWALLOWED. MAY CAUSE PULMONARY EDEMA, RESPIRATORY DAMAGE, COLLAPSE,
COUGHING, DIFFICULTY IN BREATHING. MAY CAUSE PERMANENT EYE INJURY.
TARGET ORGANS: RESPI RATORY SYSTEM, SKIN, EYES, TEETH.
Medical Cond Aggravated by Exposure:RESPIRATORY SYSTEMS, SKIN, EYES,
TEETH, ALLERGIES.
======================= First Aid Measures =======================
First Aid:GET MEDICAL CARE IMMEDIATELY IN ALL
CASES.EYES/SKIN:IMMEDIATELY FLUSH WITH WATER FOR AT LEAST 15
MINUTES.KEEP EYELIDS OPEN.INHALED:REMOVE TO FRESH AIR.PROVIDE
CPR/OXYGEN IF NEEDED.ORAL:IF CONSCIOUS,DR INK LARGE AMOUNT OF
MILK/WATER.DO NOT INDUCE VOMITING/GASTRIC LAVAGE.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS WITH FULL
FACEPIECE OPERATED IN THE POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:NEGLIGIBLE FIRE HAZARD WHEN EXPOSED TO
HEAT OR FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROPER PROTECTIVE EQUIPMENT. VENTILATE
AREA. DO NOT RELEASE INTO SOIL, SEWER, STREAM. STOP LEAK IF
POSSIBLE. NEUTRALIZE WITH SODA ASH OR LIME. WITH CLEAN SHOVEL,
PLACE MATERIAL INTO CLEAN CONTAIN ER FOR DISPOSAL. FLUSH SPILL AREA
WITH WATER.
Neutralizing Agent:SODA ASH, LIME, SODIUM BICARBONATE
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE-STORE IN TIGHTLY CLOSED
CONTAINERS,IN CORROSION-PROOF AREA,AWAY FROM METALS,BASES &
OXIDIZERS.
Other Precautions:DANGER! CORROSIVE.DO NOT GET IN EYES,ON SKIN,ON
CLOTHING.AVOID BREATHING VAPORS,MIST OR GAS.USE WITH ADEQUATE
VENTILATION.PROTECT CONTAINERS AGAINST SPILLAGE AND PHYSICAL
INJURY.FLUSH CONTAINER BEFORE DISCARDING.PUT NOTHING ELSE IN IT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NATIONAL INSTITUTE OF OCCUPATIONAL SAFETY
AND HEALTH (NIOSH) APPROVED SELF-CONTAINED BREATHING APPARATUS
OPERATED IN POSITIVE PRESSURE MODE WHEN PERMISSIBLE EXPOSURE LIMITS
ARE EXCEEDED.
Ventilation:PROVIDE GENERAL VENTILATION OR LOCAL EXHAUST TO MEET OSHA
PERMISSIBLE EXPOSURE LIMITS (OSHA PEL).
Other Protective Equipment:USE RUBBER SPLASH APRON AND RUBBER BOOTS.
EYEWASH AND SAFETY SHOWER SHOULD BE LOCATED NEARBY. DO NOT WEAR
CONTACT LENSES
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING OR DRINKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:384F,196C
Vapor Density:1.3
Spec Gravity:1.2
pH:1.1
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS OR SLIGHTLY YELLOW FUMING LIQUID -
PUNGENT ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALCOHOLIC HYDROGEN CYANIDE,METALS,AMINES,METAL OXIDES,ACETIC ANHYDRIDE,
AMYL ACETATE, FORMALDEHYDE, ALKALIES, CARBONATE
Stability Condition to Avoid:EXCESSIVE HEAT, FIRE
Hazardous Decomposition Products:CORROSIVE HYDROGEN CHLORIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT FEDERAL, COUNTY, AND LOCAL ENVIRONMENTAL
REGULATORS FOR GUIDANCE REGARDING PROPER DISPOSAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ENAMEL, ALKYD SG OLIVE DRAB, 24087 1D745406
Preparer's Name:W.A ELLISON
CAGE:FO127
CAGE:FO127
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:LEAD CHROMATE
CAS:7758-97-6
ACGIH TLV:.0500 MG/CU.M.
Ingred Name:TALC (CONTAINING NO ASBESTOS)
CAS:14807-96-6
RTECS #:WW2710000
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST; 9192
Ingred Name:SILICA, CRYSTALL-CRISTOBALITE
CAS:14464-46-1
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.05 MG/M3 RDUST9293
Ingred Name:SILICA, AMORPHOUS-DIATOMACEOUS EARTH.
CAS:60676-86-0
RTECS #:VV3280000
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:LIGROIN (PETROLEUM HYDROCARBON MIXTURE)
CAS:8032-32-4
OSHA PEL:500 PPM 2950 MG/CU.M
ACGIH TLV:100 PPM 525 MG/CU.M.
Ingred Name:MINERAL SPIRITS
CAS:64742-88-7
OSHA PEL:500 2950 MG/CU.M
ACGIH TLV:100 PPM 525 MG/CU.M.
Ingred Name:LEAD (SARA III)
CAS:7439-92-1
RTECS #:OF7525000
OSHA PEL:0.05 MG/M3;1910.1025
ACGIH TLV:0.15 MG/M3;DUST 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192
Ingred Name:VOC. ORGANIC CMPD LESS WATER, LESS EXEMPT SOLVENT (G/LITER
485); VOC MATERIAL (G/LITER 485), PER MFG S MSGS.
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:CHRONIC OVEREXPOSURE TO LEAD MAY
RESULT IN SEVERE DAMAGE TO BLLOD FORMING, NERVOUS, URINARY, AND
REPRODUCTIVE SYSTEMS. REPEATED AND PROLONGED EXPOSURE TO RELATIVELY
INSOLUBLE CHROMATES MAY CAUSE LUNGCANCER.
Explanation of Carcinogenicity:* CHROMIUM AND CERTAIN CHROMIUM
COMPOUNDS ARE LISTED AS POTENTIAL CARCINOGENS BY NATIONAL
TOXICOLOGY PROGRAM & IARC.
Effects of Overexposure:LOSS OF APPETITE, METALLIC TASTE IN MOUTH,
ANXIETY, CONSTIPATION, NAUSEA, WEAKNESS. INSOMNIA, HEADACHE, MUSCLE
AND JOINT PAIN, FINE TREMORS, NUMBNESS, DIZZINESS, HYPERACTIVITY
AND COLIC.
Medical Cond Aggravated by Exposure:PREXISTING RESPIRATORY CONDITIONS
MAY BE AGGRAVATED BY EXPOSURES TO CRYSTALLINE SILICA. PREXISTING
KIDNEY CONDITIONS MAY BE AGGRAVATED BY EXPOSURES TO LEAD.
======================= First Aid Measures =======================
First Aid:SWALLOWING:DONOT INDUCE VOMITING. CALL POISON CONTROL CENTER,
PHYSICIAN IMMED.INHALATION: REMOVE TO FRESH AIR IMMEDIATELY. IF
BREATHING HAS STOPPED, GIVE ARTIFICIAL RESPIRATION. KEEP WARM &
QUIET. OBT AIN MEDICAL ATTENTION IMMEDIATELY. EYE:FLUSH W/LARGE
AMOUNTS OF WATER FOR 15 MIN. LIFTING UPPER/LOWER LIDS FREQ. SKIN:
REMOVE CONTAMINATED CLOTHING. WASH AREA W/SOAP & WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:102F/38.9C
Extinguishing Media:NFPA CLASS B EXTINGUISHERS (CARBON DIOXIDE, DRY
CHEMICAL OR ALCOHOL FOAM. POLYMER FOAM IS PREFERRED FOR LARGE
FIRES.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHNG APPARATUS. WTR
MAYBE INEFFECTIVE,BUT MAYBE USED TO COOL EXPOSED CONTAINERS TO
PREVENT PRESSURE BUILDUP&POSSIBLE AUTO-IGNITION OVER.
Unusual Fire/Explosion Hazard:EXPOSURE TO DECOMP PRODUCTS MAY CAUSE
HEALTH HAZ. KEEP CONTAINERS CLOSED,ISOLATE FROM HEAT,ELEC
EQUIP,SPARKS & FLAME.CLOSED CONTAINER MAY EXPLODE WHEN EXPOSED.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP SPECTATORS AWAY. ELIMINATE ALL IGNITION
SOURCES. DIKE AND CONTAIN SPILL WITH INERT MATERIAL. TRANSFER
LIQUIDS TO COVERED METAL CONTAINERS FOR RECOVERY OR DISPOSAL. USE
NON SPARKING TOOLS. PREVENT CONTAMINATION OF SEWER, STREAMS
GROUNDWTR.
======================Handling and Storage ======================
Handling and Storage Precautions:DONOT STORE ABOVE 95 DEGREES F. STORE
LARGE QUANTITIES IN COMOLIANCE WITH OSHA 29CFR1910.106.
Other Precautions:DONOT TAKE INTERNALLY. CLOSE CONTAINER AFTER EACH
USE. KEEP AWAY FROM CHILDREN. DO NOT BREATHE SANDING DUST. WASH
HANDS AND FACE THOROUGHLY BEFORE EATING AND DRINKING. EMPTY
CONTAINERS MUST NOT BE WAS HED AND REUSED FOR ANY PURPOSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN GENERAL EXPOSURE TO ORGANIC CHEMICALS SUCH AS
THOSE CONTAINED IN THIS PRODUCTMAY NOT REQUIRE THE USE OF
RESPIRATORY PROTECTION IF USED IN WELL VENTILATED AREAS. RESTRICTED
VENTILATION AREAS NIOSH A PPROVED CHEMICAL CARTRIDGE MAYBE REQD.
Ventilation:PROVIDE GENERAL DILUTION AND LOCAL EXHAUST VENTILATION IN
SUFFICIENT VOLUME & PATTERN TO KEEP CONCENTRATIONS AT LOWEST.
Other Protective Equipment:AS REQUIRED TO PREVENT SKIN CONTACT. SEE
OSHA STANDARD FOR LEAD.
Supplemental Safety and Health
DO NOT TAKE INTERNALLY. CLOSE CONTAINER AFTER EACH USE. KEEP AWAY FROM
CHILDREN DO NOT BREATHE SANDING DUST. WASH HANDS AND FACE
THOROUGHLY BEFORE EATING AND DRINKING. EMPTY CONTAINERS MUST NOT BE
WAS HED AND RE-USED FOR ANY PURPOSE. CONTAINERS SHOULD BE GROUNDED
AND BONDED TO RECEIVING CONTAINER.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:280-388F
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:58
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT AND SOURCES OF
IGNITION.
Hazardous Decomposition Products:BURNING, INCLUDING WHEN HEATED BY
WELDING OR CUTTING, WILL PRODUCE SMOKE, CARBON MONOXIDE & CARBON
DIOXIDE.
Conditions to Avoid Polymerization:KEEP AWAY FORM HEAT SPARKS AND
FLAME.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE ONLY IN EPA PERMITTED FACILITY. DO
NOT INCINERTE CLOSED CONTAINERS. OBSERVE PRECAUTIONS FOR DISPOSAL
OF FLAMMABLE MATERIALS. CONTAMINATED ABSORBANT MAY BE DISPOSED IN A
HAZARDOUS WASTE LAND FILL. DISPOSE IAW FEDERAL, STATE, LOCALREGS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:4084/4088 SULFUR
CAGE:DO803
CAGE:DO803
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:SULFUR
CAS:7704-34-9
RTECS #:WS4250000
Fraction by Wt: 99-100%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT CAN CAUSE SEVERE INJURY &
DEATH IF IMPROPERLY HANDLED.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:INGESTION: IF CONSCIOUS, IMMEDIATELY GIVE LARGE AMOUNTS OF
WATER. INHALATION: REMOVE TO FRESH AIR. SKIN: IMMEDIATELY WASH
W/PLENTY OF SOAP & WATER FOR AT LEAST 15 MINS. EYES: IMMEDIATELY
FLUSH W/PLENT Y OF WATER FOR AT LEAST 15 MINS. OBTAINMEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:187C/370F
Extinguishing Media:WATER SPRAY, ALCOHOL FOAM, DRY CHEMICAL OR CO2
Fire Fighting Procedures:WEAR PROPER PROTECTIVE EQUIPMENT & SCBA W/FULL
FACEPIECE OPERATED IN POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:HIGHLY FLAMMABLE. DUST MAY FORM
FLAMMABLE/EXPLOSIVE MIXTURE W/AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SUITABLE PROTECTIVE CLOTHING. CAREFULLY
SWEEP UP & REMOVE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED.
SUITABLE FOR ANY GENERAL CHEMICAL STORAGE AREA. AVOID CONTACT
W/EYES, SKIN, & CLOTHING.
Other Precautions:DON'T SMOKE. AVOID BREATHING DUST. READ ALL
PRECAUTIONARY INFORMATION. THIS CHEMICAL MAY INTERACT W/OTHER
SUBSTANCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF AIRBORNE CONCENTRATION IS HIGH, USE AN
APPROPRIATE RESPIRATOR OR DUST MASK.
Ventilation:ADEQUATE GENERAL OR LOCAL EXHAUST: TO KEEP FUME OR DUST
LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:EYE/FACE GUARDS, LAB COAT
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
THIS PRODUCT IS USED AS A LABORATORY REAGENT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:445C/833F
Melt/Freeze Pt:M.P/F.P Text:116C/240F
Vapor Density:8.8
Spec Gravity:2.01
Solubility in Water:NEGLIGIBLE
Appearance and Odor:YELLOW CRYSTALS, POWDER, OR SOLID, ODORLESS.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AIR, STRONG OXIDIZING AGENTS, MOST COMMON METALS, HYDROGEN, CHLORINE,
FLUORINE, ORGANIC MATERIALS
Stability Condition to Avoid:SOURCES OF IGNITION & ELEVATED TEMPS
Hazardous Decomposition Products:OXIDES OF SULFUR (SULFUR DIOXIDE)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/APPLICABLE FEDERAL,
STATE, & LOCAL ENVIRONMENTAL REGULATIONS. HIGHLY FLAMMABLE. UN1350.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-C-22750 17925 WHITE, PART A M1-051
Kit Part:Y
Preparer's Name:DAVID SCHMETTERER
CAGE:DO165
CAGE:DO165
CAGE:5V430
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III) (VP =
71.2 MMHG)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 12.0%
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:NH2CH2CH(CH3)(CH2)3NH2 (VP=130.0 MMHG)
CAS:15520-10-2
RTECS #:SA0248500
Fraction by Wt: 23.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT EST.
ACGIH TLV:NOT EST.
Ingred Name:EPOXY RESIN
CAS:25085-99-8
Fraction by Wt: 19.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:EPOXY RESIN
CAS:25085-99-8
Fraction by Wt: 8.9%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICA, CRYSTALLINE - QUARTZ (MAY BE RELEASED BY SANDING
DRIED PAINT FILM)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 7.20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT EST.
ACGIH TLV:0.1 MG/M3 RDUST;9495
Ingred Name:VOC = 298.0 GPL
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT EST.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:REPEATED/PROLONGED OCCUPATIONAL
OVEREXPOSURE TO SOLVENTS ASSOCIATED W/PERMANENT BRAIN/NERVOUS
SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND
INHALING THE CONTENTS MAY BE HARMFUL O R FATAL. PROLONGED
OVEREXPOSURE (INHAL)MAY CAUSE DELAYED LUNG DISEASE.
Explanation of Carcinogenicity:FROM INITIAL LIMITED TESTS/STUDIES IARC
CONCLUDES IS LIMITED EVIDANCE OF CARCINOGENICITY FROM CRYSTALINE
SILICA.
Effects of Overexposure:OVEREXPOSURE MAY PRODUCE VARIOUS EFFECTS. ACUTE
TOXICITY (HEADACHE, DIZZINESS, NAUSEA, LOSS CONSCIOUSNESS. SEVERE
EYE IRRITATION POSSIBLY RESULTING PERMANENT DAMAGE. IRRITATED
MUCOUS MEMBRANES. VOMITI NG FROM INGESTION. SKIN DEFATTING/DRYING.
SENSITIZATION AFTER REPEATED CONTACT.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/PLENTY CLEAN H20 15 MIN, LIFTING LIDS, GET MED
ATTN. INHAL: GET FRESH AIR, PROVIDE OXYGEN IF BREATH DIFFICULT.
GIVE ARTIF RESP IF NOT BREATHING. GET MED ATTN. KEEP VICTIM
WARM/QUIET. NEVE R GIVE UNCONS PERSON LIQ. INGEST: CALL DR. IMMED.
DON'T INDUCE VOMIT. IF VOMIT SPONTANEOUSLY, KEEP HEAD BELOW HIPS.
SKIN: FLUSH W/H20 WHILE REMOVING CONTAM CLOTHES/SHOES. IF IRRIT
PERSIST, GET MED AID
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:22.0F,-5.6C
Lower Limits:1.4
Extinguishing Media:FOAM, CO2, OR DRY CHEMICAL
Fire Fighting Procedures:WATER MAY BE USED TO KEEP EXPOSED CONTAINERS
COOL & KEEP FLAMMABLE STRUCTURE WETDON'T ENTER FIRE AREA WITHOUT
PROPER PROTECTION, HAZARDOUS DECOMP MAY BE PRESENT
Unusual Fire/Explosion Hazard:WATER PRESSURE MAY SPREAD A FLAMMABLE
LIQUID FIRE. SEALED CONTAINERS MAY EXPLODE IF OVER HEATED.
================== Accidental Release Measures ==================
Spill Release Procedures:WARNING - FLAMMABLE. ELIMINATE ALL IGNITION
SOURCES. HANDLING EQUIPMENT MUST BE GROUNDED TO PREVENT SPARKING.
SOAK UP WITHABSORBENT & PLACE IN NON-LEAKING CONATINERS. SEAL
TIGHTLY FOR PROPER DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:TREAT AS A HAZARDOUS-FLAMMABLE
MATERIAL. KNOW APPLICABLE D.O.T. REG. BEFORE ATTEMPTING TO
TRANSPORT THIS MATERIAL.
Other Precautions:WARNING: HOT ORGANIC CHEMICAL VAPORS OR MISTS ARE
SUSCEPTIBLE TO SUDDEN SPONTANEOUS COMBUSTION WHEN MIXED W/AIR.
IGNITION MAY OCCUR @ TEMPS BELOW THOSE PUBLISHED AS
AUTOIGNITION/IGNITION TEMPS. IGNITI ON TEMPS DECREASE W/INCREASING
VAPOR*
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IMPORTANT-MUST PROVIDE ADEQUATE VENT TO MAINTAIN
VAPOR CONCENTRATE BELOW ESTAB- LISHED TLV LIMIT AS GIVEN BY OSHA.
IN MORE CONFINED AREAS A NIOSH/MSHA APPROVED RESPIRATOR EQUIPPED
WITH ORGANIC VAPOR C ARTRIDGE SHOULD BE WORN.
Ventilation:MUST PROVIDE ADEQUATE VENTILATION, SEE PARAGRAPH ABOVE.
Other Protective Equipment:HAVE EYE BATH & SAFETY SHOWER AVAILABLE.
Supplemental Safety and Health
KEY1:N1. * VOLUME & VAPOR/AIR CONTACT TIME AND ARE INFLUENCED BY PRESS
CHANGES. IGNITION MAY OCCUR AT TYPICAL ELEVATED TEMP PROCESS
CONDITIONS, ESPECIALLY IN PROCESS OPERATING UNDER VACUUM IF
SUBJECTE D TO SUDDEN INGRESS OF AIR, OUTSIDE PROCESS EQUIPMENT
OPERATING UNDER ELEVATED PRESS IF SUDDEN ESCAPE OF VAPORS/MISTS.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:175 TO 344F
Vapor Density:>AIR
Spec Gravity:1.35
pH:NA
Viscosity:73 KU
Evaporation Rate & Reference:3.5 X N-BUTYL ACETATE
Solubility in Water:SLIGHT
Appearance and Odor:WHITE, SOLVENT ODOR
Percent Volatiles by Volume:36.2
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS & STRONG ALKALIES. NOT CORROSIVE TO METAL.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAMES, STRONG
ALKALIES, & OXIDIZING AGENTS.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION OR PRODUCTS LIKE
THIS MAY GENERATE HIGHLY POISONOUS CARBON MONOXIDE AND OTHER TOXIC
GASES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH CURRENT
LOCAL, STATE & FEDERAL REG. CONTACT AN APPROVED DISPOSAL FACILITY
| 1 | gloves_mandatory |
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.