text
stringlengths 542
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:118A200 SEVEN STAR GLOSS OIL HOUSE AND TRIM
CAGE:ACEHA
CAGE:ACEHA
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL SPIRITS
CAS:64742-47-3
Fraction by Wt: 11.6%
OSHA PEL:500 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:ETHANOL, 2-PROPOXY-; (2-PROPOXYETHANOL)
CAS:2807-30-9
RTECS #:KM2800000
Fraction by Wt: 0.9%
OSHA PEL:50 PPM (MFR)
ACGIH TLV:50 PPM (MFR)
Ingred Name:CARBONIC ACID, CALCIUM SALT (1:1); (CALCIUM CARBONATE)
CAS:471-34-1
RTECS #:FF9335000
Fraction by Wt: 10.4%
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 30.0%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:STODDARD SOLVENT; (MINERAL SPIRITS)
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 3.6%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRITATION OF EYES, SKIN AND
RESPIRATORY SYSTEM MAY OCCUR ON OVEREXPOSURE. MAY ALSO CAUSE
NERVOUS SYSTEM DEPRESSION. CHRONIC: PROLONGED OVEREXPOSURE TO
SOLVENTS MAY CAUSE ADVERSE EFFECTS TO THE LIVER AND URINARY
SYSTEMS. SOLVENTS WITH PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HEADACHE, DIZZINESS, NAUSEA AND LOSS OF
COORDINATION ARE INDICATIONS OF EXCESSIVE EXPOSURE TO VAPORS OR
SPRAY MISTS.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP
WARM AND QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP AND
WATER. EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. GET MEDICAL ATTENTION. INGESTION: CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:105F,41C
Lower Limits:0.9%
Extinguishing Media:FOR DRY SOLIDS, USE WATER, FOAM, CARBON DIOXIDE,
DRY CHEMICALS.
Fire Fighting Procedures:WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP.
WATER MAY BE USED TO COOL CLSD CONTRS TO PVNT PRESS BUILD-UP & POSS
AUTO IGNIT/EXPLO WHEN EXPOS TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPKS & OPEN FLAME. HEAT MAY CAUSE PRESS BUILD-UP
IN CLSD CONTRS. WATER MAY BE USED TO COOL.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTENTS ARE COMBUSTIBLE. KEEP AWAY
FROM HEAT AND OPEN FLAME. USE APPROVED BONDING AND GROUNDING
PROCEDURES.
Other Precautions:TRANSFER ONLY TO APPROVED, PROPERLY MARKED
CONTAINERS. KEEP OUT OF REACH OF CHILDREN. INTENTIONAL MISUSE BY
DELIBERATELY INHALING THE CONTENTS CAN BE HARMFUL OR FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:PROPERLY FITTED ORGANIC VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH.
Ventilation:LOCAL EXHAUST PREFERABLE.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:308F,153C
Vapor Density:HVR/AIR
Spec Gravity:1.08 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:COLORED PIGMENTED LIQUID WITH SOLVENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS. DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE, AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FREON TF SOLVENT;FREON PCA
Preparer's Name:T.D.ARMSTRONG,C&P DEPT
CAGE:73925
CAGE:73925
============= Composition/Information on Ingredients =============
Ingred Name:1,1,2-TRICHLORO-1,2,2-TRIFLUOROETHANE (FREON 113) (SARA
III)
CAS:76-13-1
RTECS #:KJ4000000
Fraction by Wt: 100%
OSHA PEL:1000PPM/1250STEL
ACGIH TLV:1000PPM/1250STEL9192
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
LD50 LC50 Mixture:LC 50 RATS 52,000 PPM/4HRS
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION:SUFFOCATION,LIGHT
HEADACHE,GIDDINESS,NARCOSIS,CARDIAC
IRREGULARITIES;SKIN:IRRITATION;EYES:DISCOMFORT. CHRONIC:DEFAT OR
DERMATITIS;CARDIOVASCULAR DISEASE.
Effects of Overexposure:LIGHT-HEAD,GIDDY,SHORT OF BRTH,POSSIBL
NARCOSIS,POSSIBLE CARDIAC ARRHYTHNIAS AT HIGH CONCENTTATIONS.
======================= First Aid Measures =======================
First Aid:DO NOT GIVE EPINEPHRINE OR SIMILAR DRUGS.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CNTND BRTHG APP IF INVOLVED IN FIRE.
Unusual Fire/Explosion Hazard:NONE NOTED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA.ELIMINATE IGNITION
SOURCES,ESPECIALLY LOW AREAS WHERE VAPORS MIGHT COLLECT.STOP
LEAK.WEAR PROTECTIVE CLOTHES,SCBA.ABSORB SM SPILL WITH SUITABLE
ABSORBENT.SHOVEL INTO CONTAINER.LQ SPILL: DIKE WITH SUITABLE
ABSORBENT FOR LATER DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLEAN,DRY WELL VENTED
AREA.KEEP CONTAINERS CLOSED.PROTECT FROM PHYSICAL DAMAGE.DO NOT
STORE ABOVE 125F.
Other Precautions:FOR FURTHER INFORMATIONS,SEE FREON PRODUCTS BULLETIN
S-16,FST-1,S-24,S-30.
============= Exposure Controls/Personal Protection =============
Ventilation:MECHAN. IN LOW PLACES;LOCAL EXHAUST WHEN LARGE AMTS
RELEASED
Other Protective Equipment:USE APPROPIATE HYGIENE PRACTICES.
Supplemental Safety and Health
MATERIAL MEETS REQUIREMENTS FOR TYPE I UNDER MIL-C-81302.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:118F/48C
Vapor Pres:334
Vapor Density:6.5
Spec Gravity:1.57
pH:NEUTRL
Evaporation Rate & Reference:0.1 (CCL*4=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS LIQUIDS-SLIGHT ETHEREAL ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALI OR ALKALINE EARTH METALS POWDERED AL,ZN,BE,ETC.
Stability Condition to Avoid:HIGH TEMPERATURES,IGNITION SOURCES
Hazardous Decomposition Products:HYDROCHLORIC & HYDROFLUORIC
ACIDS-POSSIBLE CARBONYL HALIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:ELIMINATE IGNITION SOURCES.CONTACT QUALIFIED
DISPOSAL CONTRACTOR OR MANUFACTURER FOR DISPOSAL METHODS.SEND TO
MFR/DISPOSAL CONTRACTOR FOR RECYCLE BY DISTILLATION.PACKAGE &
DISPOSE IN ACCORDANCE WITH L OCAL,STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CE3000 CYAN REPLENISHER 3000-6C
CAGE:14774
CAGE:14774
============= Composition/Information on Ingredients =============
Ingred Name:ACRYLIC POLYMER/RESIN; (ACRYLIC COPOLYMER/RESIN)
CAS:28430-58-2
Fraction by Wt: < 1.0%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PIGMENTS (BLUE)
Fraction by Wt: < 1.0%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:NAPHTHOL SPIRITS; (MINERAL SPIRITS)
CAS:64742-48-9
Fraction by Wt: >98%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL,RAT) 5 G/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITANT TO EYES - MAY CAUSE
CONJUNCTIVITIS. SKIN: PROLONGED CONTACT CAUSES DEFATTING, DRYING,
CRACKING, DERMATITIS. INHAL: NOT NORMALLY AN INHALATION HAZARD,
OVEREXP MAY CAUSE HEADACHE, NAUSEA A ND POSSIBLE GASTROINTESTINAL
IRRITATION.INGEST: NAUSEA & POSSIBLE GI IRRITATION. TARGET ORGANS:
EYES, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: SKIN, RESPIRATORY SYSTEM. RPTD INHAL
EXPOSURE TO RATS OF A SIMILAR HYDROCARBON AT CONCS GREATER THAN OR
EQUAL TO 300 PPM IN AIR CAUSED LOW GRADE (MILD) ANEMIA AND KIDNEY
EFFECTS.
Medical Cond Aggravated by Exposure:DERMATITIS.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/LARGE AMOUNTS OF WATER, INCLUDING UNDER EYELIDS.
SKIN: WASH WITH SOAP AND WATER. REMOVE ANY CONTAMINATED CLOTHING.
INHAL: MOVE TO FRESH AIR; IF BREATHING DIFFICULTY, ADMINISTER
OXYGEN ANDGET MEDICAL HELP. INGEST: DO NOT INDUCE VOMITING DUE TO
ASPIRATION HAZARD. CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>103F,>39C
Lower Limits:0.8%
Upper Limits:7%
Extinguishing Media:FOAM, DRY CHEMICAL, CO*2, WATER FOG.
Fire Fighting Procedures:AVOID WATER, IT TENDS TO SPREAD HYDROCARBON
FIRES. WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT
.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES. COLLECT ON INERT
ABSORBENT MATL. PLACE IN WASTE CNTNR APPROVED FOR COMBUSTIBLE
WASTE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED, COOL, WELL-VENTILATED
AREA, AWAY FROM HEAT AND FLAME.
Other Precautions:READ AND FOLLOW LABEL PRECAUTIONS. DO NOT REUSE
CONTAINER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED. NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST: TO MAINTAIN BELOW TLV.
Other Protective Equipment:AN ANSI APPRVD EYEWASH STATION DESIRABLE IF
SPLASHING IS A POSSIBILITY.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:>320F,>160C
Vapor Pres:1 @ 68F
Vapor Density:5
Spec Gravity:0.76
Evaporation Rate & Reference:0.25-0.45
Solubility in Water:IMMISCIBLE
Appearance and Odor:BLUE/SLIGHT
Percent Volatiles by Volume:80-100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
VERY STRONG OXIDANTS LIKE CHROMIC ACID OR LIQUID CHLORINE.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:TREAT AS HAZARDOUS WASTE AND DISPOSE IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL ENVIRONMENTAL REGULATIONS
. DO NOT POUR DOWN COMMON DRAIN.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NICKEL CADMIUM BATTERIES
Preparer's Name:DGSC-SSH
CAGE:57932
CAGE:0FTM0
CAGE:57932
============= Composition/Information on Ingredients =============
Ingred Name:CADMIUM OXIDE (SARA III)
CAS:1306-19-0
RTECS #:EV1925000
Fraction by Wt: 8-15% %
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.2 MG (CD)/M3 DUST
ACGIH TLV:0.01 MG(CD)/M3; 9394
Ingred Name:CADMIUM HYDROXIDE
Fraction by Wt: SEE #1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.1 MG/M3 (CD FUME)
ACGIH TLV:0.05 MG/M3 (CD FUME)
Ingred Name:LITHIUM HYDROXIDE
CAS:1310-65-2
Fraction by Wt: <0.4%
Other REC Limits:NONE SPECIFIED
Ingred Name:NICKEL HYDROXIDE (SARA III)
CAS:12054-48-7
RTECS #:QR7040000
Fraction by Wt: 3-5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 MG (NI)/M3
ACGIH TLV:0.1 MG(NI)/M3; 9394
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 2-4%
Other REC Limits:NONE SPECIFIED
OSHA PEL:C 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:EYES/SKIN: CAN CAUSE BURNS AND
PERMANENT INJURY DUE TO CAUSTIC POTASSIUM HYDROXIDE(KOH). CADMIUM
AND NICKEL AND THEIR COMPOUNDS CAN CAUSE CHRONIC HEALTH PROBLEMS
SUCH AS CANCER, RENAL FAILURE AND RESP IRATORY PROBLEMS.
Explanation of Carcinogenicity:NICKEL AND CADMIUM AND THEIR COMPOUNDS
ARE KNOWN OR SUSPECT CARCINOGENS.
Effects of Overexposure:EYE AND SKIN BURNS FROM POTASSIUM HYDROXIDE.
CENTRAL NERVOUS SYSTEM DISORDERS AND CANCERS FROM LONG TERM EFFECTS
OF HEAVY METAL POISONING.
Medical Cond Aggravated by Exposure:PERSONS WITH SKIN AND RESPIRATORY
DISORDERS MAY BE AT INCRESED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:FLUSH WITH WATER. FOR EYE CONTACT, FLUSH WITH LARGE AMOUNTS
OF WATER FOR 15 MINUTES AND CONTACT A PHYSICIAN IMMEDIATELY. IF
INHALATION EXPOSURE, REMOVE TO FRESH AIR AND CONSULT A PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL AS APPROPRIATE FOR SURROUNDINGS.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS SUCH AS TOXIC
CADMIUM OXIDE FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID EYE AND SKIN CONTACT WHEN DISCARDING
USED BATTERIES.
Neutralizing Agent:5% ACETIC ACID OR VINEGAR
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE IN A DRY
PLACE.
Other Precautions:AIR BREATHER UNITS ARE NEEDED IF MATERIALS ARE
INCINERATED. INCINERATION IS NOT RECOMMENDED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL PRECAUTIONS UNLESS AT HIGH
TEMPERATURE IN WHICH CASE AIR BREATHER UNITS ARE REQUIRED.
Ventilation:NO SPECIAL PRECAUTIONS.
Other Protective Equipment:RUBBER OR PLASTIC GARMENTS.
Work Hygienic Practices:AVOID EYE/SKIN CONTACT WITH LEAKING BATTERIES.
Supplemental Safety and Health
AVOID HIGH TEMPERATURE USE. DANGEROUS FUMES OF CADMIUM OXIDE SUBLIME AT
2800F AVOID CONTINUOUS SHORT CIRCUITS BECAUSE OF THE HIGH CELL
TEMPERATURES WITH ATTENDANT SKIN BURNS. IF SOLDERING OR WELDING T O
THE CASE OF THE BATTERY IS REQUIRED USE CELLS TABBED BY MULTIPLIER
OR CONSULT MANUFACTURER FOR ADVICE.
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:EACH BATTERY CELL IS A SEALED PLASTIC CONTAINER
ENCLOSING THE ELECTROLYTES.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ANY SUBSTANCE WHICH WOULD CORRODE THE CASING AND CAUSE LEAKAGE OF THE
BATTERY ELECTROLYTE.
Stability Condition to Avoid:HIGH TEMPERATURES AND OPEN FLAMES
Hazardous Decomposition Products:BATTERY MAY EMIT HAZARDOUS VAPORS OF
POTASSIUM HYDROXIDE AND CADMIUM AND NICKEL AND THEIR COMPOUNDS WHEN
HEATED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE. BROKEN BATTERIES OR WITH
LEAKING ELECTROLYTE CONSTITUTE HAZARDOUS WASTE. CONSULT WASTE
DISPOSAL OFFICIALS FRO ADVICE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:OXYGEN
CAGE:4A579
CAGE:0MZ76
CAGE:4A579
============= Composition/Information on Ingredients =============
Ingred Name:OXYGEN
CAS:7782-44-7
RTECS #:RS2060000
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:NONE EXPECTED AS MATERIAL IS A
GAS. SKIN:NONE EXPECTED AS MATERIAL IS A GAS. CONTACT WITH LIQUID
CAUSES FROSTBITE. INHALATION:NONE IS EXPECTED. INGEST:DUE TO THE
PHYSICAL FORM OF THIS MATERIAL IT IS UNLIKELY THAT IT COULD BE
INGESTED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . SKIN:SLOWLY WARM AFFECTED
AREA WITH TEPID WATER. GET MEDICAL ATTENTION. EYES:FLUSH WITH LAR
GE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES, LIFTING UPPER AND
LOWER LIDS OCCASIONALLY. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:SUPPORTS COMBUSTION, OXIDIZER.
================== Accidental Release Measures ==================
Spill Release Procedures:RELEASE TO ATMOSPHERE, PRESENTS NO HEALTH
HAZARDS. SEE OTHER PRECAUTIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NEVER PERMIT OIL, GREASE OR OTHER
READILY COMBUSTIBLE SUBSTANCES TO COME IN CONTACT WITH OXYGEN
CYLINDERS, VALVES, REGULATORS, GAUGES OR FITTINGS.
Other Precautions:AVOID CYLINDERS TO COME IN CONTACT WITH ELECTRICAL
CIRCUITS WHEN WELDING. DO NOT PERMIT FOREIGN MATERIALS TO ENTER
CYLINDER. DON'T STORE NEAR COMBUSTIBLE GASES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NOT REQUIRED UNDER NORMAL CONDITIONS OF
USE.
Ventilation:NOT REQUIRED UNDER NORMAL CONDITIONS OF USE.
Other Protective Equipment:SAFETY SHOES.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
VP:2,200 PSIG @ 20C. SOL IN H*2O:4.89 CM3/100 CM3 H*2O. EYE PROT:AND
FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
HCC:G4
Boiling Pt:B.P. Text:-297F,-183C
Melt/Freeze Pt:M.P/F.P Text:-62F,-52C
Vapor Pres:SUPP DATA
Vapor Density:1.105
Spec Gravity:1.32 (H*2O=1)
Solubility in Water:SUPP DATA
Appearance and Odor:ODORLESS, COLORLESS, TASTELESS.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NYLON.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:OZONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . RETURN PARTIALLY UNUSED CYLINDERS TO SGP FOR PROPER
DISPOSAL.
| 1 | gloves_mandatory |
=======================================================
Product ID: 121722, TUFF-BOND HANGER ADHESIVE (FOR (SUPDAT)
Cage: 0P1J0
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 01PJ0
Box: UNKNOW
Cage: 0P1J0
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: INGEST: CAN CAUSE GI IRRIT, NAUS & VOMIT. ASPIR
OF MATL INTO LUNG MAY CAUSE CHEM PNEUM WHICH CAN BE FATAL. INHAL: MAY CAUSE
NOSE/THROAT IRRIT. HIGH CONCS MAY CAUSE ACUTE CNS DEPRESS CHARACT BYHDCHS,
DIZZ, NAUS & CONFUSION. EYES: MAY CAUSE IRRIT. SKIN: MAY CAUSE DEFAT
& IRRIT OF SKIN. CHRONIC: (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ: TOLUENE APPEARS ON THE NAVY LIST
OF OCCUP CHEM REPRO HAZS. SEEK CONSULTATION FROM APPROP HLTH PROFESSIONALS
CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG & EXPOS INFO (FP N).
RPTD OVEREXP TO TOLUENE MAY CAUSE LIVER DMG. REPORTS HAVE ASSOC PRLNGD &
RPTD OCCUP TO SOLVS W/PERM BRAIN & NERVOUS SYS DEPRESS.(SUPDAT)
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INGEST: IF SWALLOWED DO NOT INDUCE VOMIT. CALL POIS CTL CTR,
HOSPITAL EMER ROOM OR MD IMMED. INHAL: REMOVE TO FRESH AIR IMMED. IF BRTHG
HAS STOPPED, GIVE ARTF RESP. KEEP WARM & QUIET. GET MED ATTN IMM ED. EYE:
FLUSH W/LG AMTS OF WATER LIFTING UPPER & LOWER LIDS OCCASNLY. CONTINUE
FOR AT LEAST 15 MIN. GET MED ATTN. SKIN: REMOVE CONTAMD CLTHG. WASH AFFECTED
AREA W/SOAP & WATER. OBTAIN MED
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: KEEP SPECTATORS AWAY. ELIMINATE ALL IGNIT SOURCES
(FLAMES, HOT SURFS & SOURCES OF ELEC, STATIC OR FRICTIONAL SPARKS). DIKE
& CONTAIN SPILL W/INERT MATL (EG SAND, EARTH). TRANSFER LIQS TO COVERRED
META L CNTNRS FOR RECOVERY OR DISPOSAL OR
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE I/A/W FEDERAL, STATE & LOCAL REGULATIONS.
THIS PRODUCT, IF DISCARDED DIRECTLY, WOULD BE CLASSIFIED A HAZARDOUS WASTE
BASED ON ITS IGNITABILITY CHARACTERISTIC, IE HAS FLASH POINT OF 140F (60C)
OR LESS. PROPER RCRA CLASSIFICATION WOULD BE D001.
Handling And Storage Precautions: DO NOT STORE ABOVE 115F (46C). STORE LARGE
QUANTITIES IN COMPLIANCE WITH OSHA 29 CFR 1910.106.
Other Precautions: DO NOT TAKE INTERNALLY. CLOSE CNTNR AFTER EACH USE. EMPTY
CNTNRS MUST NOT BE WASHED & REUSED FOR ANY PURPOSE. CNTNRS SHOULD BE
GROUNDED & BONDED TO RECEIVING CNTNR. DO NOT WELD, BRAZE OR CUT ON EMPTY
CNTNR. NEVER USE PRESS TO EMPTY.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: 40.0F,4.4C
Extinguishing Media: USE NFPA CLASS B FIRE EXTINGS (CARBON DIOXIDE, ALL PURPOSE
DRY CHEM OR ALCOHOL FOAM) DESIGNED TO EXTING FLAM (SUPDAT)
Fire Fighting Procedures: USE NIOSH APPRVD SCBA & FULL PROT EQUIP (FP N).
WATER MAY BE INEFTIVE BUT MAY BE USED TO COOL EXPOS CNTNRS TO PVNT PRESS
BUILDUP & POSS AUTOIGNIT OR (SUPDAT)
Unusual Fire/Explosion Hazard: DURING EMER CNDTNS, OVEREXP TO DECOMP PRODUCTS
MAY CAUSE HEALTH HAZARD. SYMPTOMS MAY NOT BE IMMEDIATELY APPARENT. OBTAIN
MEDICAL ATTENTION. WARNING! FLAMMABLE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: PROPER SELECTION OF RESP PROT DEPENDS UPON MANY FACTORS
INCLUDING DURATION/LEVEL OF EXPOS & CNDTNS OF USE. IN GEN EXPOS TO
ORGANIC EHMS SUCH AS THOSE CONTAINED IN THIS PROD MAY NOT REQ THE USE OF RESP
PROT IF USED IN WELL VENTD
Ventilation: PROVIDE LOC EXHST VENT IN SUFFICIENT VOL & PATTERN SO AS TO
MAINTAIN EXPOS BELOW NUISANCE DUST LIMITS &
Other Protective Equipment: ANSI APPROVED EYE WASH & DELUGE SHOWER (FP N).
OTHER PROTECTIVE EQUIPMENT NOT LIKELY TO BE NEEDED.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: MFR'S TRADE NAME/PART NO: INSULATION CLIPS).
EXTING MEDIA: LIQ FIRES. POLYMER FOAM IS PREF FOR LARGE FIRES. FIRE FIGHT
PROC: EXPLO WHEN EXPOSED TO EXTREME HEAT. IF WATER IS USED, FOG NOZZS ARE
PREF. E FTS OF OVEREXP: INTENTIONAL MISUSE BY DELIB CONC & INHAL CONTENTS
MAY BE HARMFUL/FATAL. TOLUENE HAS BEEN FOUND
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 231F,111C
Vapor Pres: SEE ING 1
Vapor Density: HVR/AIR
Spec Gravity: 1.0
VOC Grams/Liter: 612
Evaporation Rate & Reference: SLOWER THAN DIETHYL ETHER
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume: 70
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: AVOID EXCESSIVE HEAT (>115F,46C) AND SOURCES OF
IGNITION.
Materials To Avoid: STRONG ADICS OR ALKALINE MATERIALS.
Hazardous Decomposition Products: BURNING, INCLUDING WHEN HEATED BY WELDING OR
CUTTING WILL PRODUCE SMOKE, CARBON MONOXIDE AND CARBON DIOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: VOLATILE ORGANIC COMPOUND: 5.10 LB/GAL LESS WATER &
NPRS; 612 G/L LESS WATER CALCULATED; 17.55 LB/GAL SOLIDS;
=======================================================
HAZCOM Label
=======================================================
Product ID: 121722, TUFF-BOND HANGER ADHESIVE (FOR (SUPDAT)
Cage: 0P1J0
Company Name: GEMCO INC
Street: 1019 GRIGGS ST
Zipcode: 61832
Label Required IND: Y
Date Of Label Review: 01/21/1997
Status Code: C
Label Date: 01/21/1997
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: EXTREMELY FLAMMABLE. ACUTE: INGESTION: GASTROINTESTINAL
IRRITATION, NAUSEA AND VOMITING. ASPIRATION INTO LUNGS MAY CAUSE POSSIBLY
FATAL CHEMICAL PNEUMONITIS. INHALATION: NOSE OR THROAT IRRITATION, ACU TE
CENTRAL NERVOUS SYSTEM DEPRESSION WITH HEADACHE, DIZZINESS, NAUSEA AND
CONFUSION. EYES: IRRITATION. SKIN: DEFATTING AND IRRITATION OF SKIN. CHRONIC:
TOLUENE APPEARS ON THE NAVY OCCUPATIONAL CHEMICA L REPRODUCTIVE HAZARDS LIST
(FP N). TOLUENE MAY CAUSE LIVER DAMAGE. OVEREXPOSURE TO SOLVENTS HAS BEEN
ASSOCIATED WITH PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE
MAY BE HARMFUL OR FA TAL.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TURCO 4931 PART B
Kit Part:Y
Preparer's Name:JOHN P. JONES
CAGE:61102
CAGE:61102
============= Composition/Information on Ingredients =============
Ingred Name:OXALIC ACID
CAS:144-62-7
RTECS #:RO2450000
Fraction by Wt: 30%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3/2 STEL; 9596
Ingred Name:SODIUM DODECYLBENZENE SULFONATE (CERCLA). CERCLA RQ:1000.
CAS:25155-30-0
RTECS #:DB6825000
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:1-HEXYN-3-OL; HEXYNOL
CAS:105-31-7
RTECS #:MR0181000
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:CITRIC ACID
CAS:77-92-9
RTECS #:GE7350000
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM SULFATE
CAS:7757-82-6
RTECS #:WE1650000
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:PROD/PROD DUST/SOLN CONTACT MAY
CAUSE CHEM BURNS;POSSIBLE PERM DMG.SKIN:PROD/PROD DUST/SOLN CONTACT
MAY CAUSE SEVERE IRRIT,POSSIBLE CHEM BURNS,POSSIBLE PERM TISSUE
DMG.INHAL:DUST/MIST MAY CAUSE SE VERE IRRIT,POSSIBLE PERM DMG TO
UPPER RESP TRACT.INGEST:SEVERE IRRIT TO GI,POSSIBLE DMG MAY BE
HARMFUL/FATAL.
Explanation of Carcinogenicity:PER MSDS:CARCINOGENS:NONE(AS DEFINED IN
29CFR 1910.120, APPENDIX A(1)).
Effects of Overexposure:CHEM EYE BURNS, PERMANENT DMG, SEVERE SKIN
IRRIT, CHEM SKIN BURNS, PERM SKIN TISSUE DMG, SEVERE IRRIT WHEN
INHAL, PERM DMG TO UPPER RESP TRACT, SEVERE IRRIT WHEN INGEST, DMG
TO GI TRACT, HAMRFUL/FATALIF SWALLOWED.TOXIC EFFECTS MAY NOT
APPEAR IMMED.
Medical Cond Aggravated by Exposure:PROLONGED OVEREXPO TO FUMES FROM
HOT OXALIC ACID SOLN MAY LEAD TO RENAL IMPARIMENT,AGGRAVATING ANY
PREEXISTING KIDNEY DYSFUNCTION. NO KNOWN CHRONIC EFFECTS THAT
DIFFER FROM ACUTE EFFECTS.
======================= First Aid Measures =======================
First Aid:EYE:SPEED ESSENTIAL.IMMED BEGIN FLUSH W/LG VOLS OF H2O.CONT
5MINS.FOLLOW W/NORMAL SALINE FOR 30-60MINS.HOLD EYELIDS APART.GET
IMMED MED ATTN.SKIN:FLUSH W/LG VOLS OF H2O.CONT @LEAST
15MINS.IRRIT/BLISTE R OCCURS GET MED ATTN.INHAL:REMOVE TO FRESH
AIR.BREATH DIFFI ADMIN OXY.IRRIT GET MED ATTN.INGEST:DONT INDUCE
VOMIT EXCEPT ON ADVICE OF MED PERSON.CONSC DILU BY GIVING LG VOL OF
SOLUBLE CALCIUM IN(SUP)
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Autoignition Temp:Autoignition Temp Text:NP
Lower Limits:NP
Upper Limits:NP
Fire Fighting Procedures:USE SELF-CONTAINED RESPIRATORY PROTECTION.
Unusual Fire/Explosion Hazard:CONTACT W/H2O/REACT METALS(MG,ETC)MAY
LEAD TO H2 GASS GENERATION IN EXPLO AMTS.EXPO TO ELEV TEMPS UNDER
FIRE COND MAY LEAD TO TOXIC/CORR BROMINE VAP GENERATION.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEANUP PERSON USE APPRP PROT EQPMT.SHOVEL DRY
SPILL INTO DOT APRROV DR FOR DISP.KEEP DRY TIL AS MUCH AS POSSIBLE
HAS BEEN SWEPT UP/SHOVEL.RESIDUAL AMTS DISSOLVE IN WATER,SOLN
COLLECT IN DOT APPROV DR FOR DISPO.NEUTRA AREA W/SODA ASH
SOLN.(SUPPLE)
Neutralizing Agent:SODA ASH SOLUITION.
======================Handling and Storage ======================
Handling and Storage Precautions:USE APPROP SAF EPMT.ADD SLOWLY TO
TEPID H2O WHILE MIX.NEVER DUMP LG AMTS INTO H2O-VIOLE STEAM
ERUPTION.ADD ONLY AS FAST AS PROD DISSOLVE.ADD SLOW/CAUT
Other Precautions:DISPO:DISPO AS 1,2 ABOVE OR SPENT SOLN/RINSE
NEUTR,SEPARATE FLOATABLE SOIL.ANY RESIDUAL ORG MATTER REMOVE BY
OXIDATION &/OR CARBON TREAT.CLARIFIED H2O RELEASE TO SEWER IF LOC
REGS PERMIT. STORE PRODUC T IN DRY PROTECTED AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR DUST/MIST CONDITIONS NIOSH-APPROV RESP FOR
TOXIC DUST/MIST ADVISED.IF RESPIRATORS ARE USED FORMAL
TRAINING/SCREENING PROGRAM MUST BE INITIATED.SEE 29CFR1910.134.
Ventilation:MAINTAIN SUFFICIENT MECHANICAL VENTILATION TO KEEP VAPOR
CONCEN BELOW TLV.
Other Protective Equipment:BOOTS/APRON MADE OF ACID RESISTANT
MATERIAL(VITON,PVC,ETC).PROTECTIVE SUIT NOT NORMALLY REQUIRE BUT
ADVISED IF NECESSARY
Work Hygienic Practices:WASH HANDS/FACE W/SOAP/H2O BEF SMOKE/EAT.IMMED
REMOVE ALL CONT CLOTH;WASH SEPARATELY BEF REUSE.DISCARD SHOES INTER
CONTA
Supplemental Safety and Health
PH:3% IN SOLN=1.5. 1STAID:ANY FOMR(MILK,CALCIUM GLUCONATE SOLN,CALCIUM
LACTATE SOLN)GET IMMED MED ATTN. SPILL:TREAT NEUTRA WASH PER DISPO
SEC,RELEASE TO SEWER IF REGS PERMIT.SOLN:CONFINE SPILL.STOP LE AK
W/O RISK.VENTI AREA.REMOVE NONESSENTPERSON TIL CLEANUP
COMPLETE.PUMP/ABSORB INTO DR.WASH/NEUTRA AREA.COLLECT WATER
================== Physical/Chemical Properties ==================
HCC:C3
Boiling Pt:B.P. Text:NA
Melt/Freeze Pt:M.P/F.P Text:NP
Decomp Temp:Decomp Text:NP
Vapor Pres:N/AVAI
Vapor Density:NA
Spec Gravity:NA
pH:SUPPLE
Viscosity:NP
Evaporation Rate & Reference:NA
Solubility in Water:NA
Appearance and Odor:OFF WHITE DAMP, GRANULES, MILD ODOR
Percent Volatiles by Volume:NA
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONTACT W/STRONG ALKALIES,REACTIVE METALS, ORGANIC MATERIALS.
Stability Condition to Avoid:CONTACT W/STRONG ALKALIES,REACTIVE METALS,
ORGANIC MATERIALS
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY PRODUCE
CARBON NOMOXIDE,DIOXIDE,& OTHER TOXIC VOLATILE ORGANIC CMPDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONC:1)TRANSF TO RECLAIM
CNTR-RECYCLE,REUSE.2)TRANSF TO LIC HAZ WASTE TREAT/DISP SITE-DISPO
PER APPLIC LOC/STATE/REG REGS AS HAZ WASTE.3)SM AMTS DISSOLVE IN
H2O,TREAT AS BELOW.CLARIFIED H2O RELEASE TO SEWER IF LOC REGS
PERMIT.SOLN/RINSE:(OTHERPRECAU)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:51802, CLOVER SILICON CARBIDE GREASE (SUPDAT)
Preparer's Name:CATHY GRIFFITH
CAGE:GO402
CAGE:GO402
CAGE:73165
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED (SEVERE)
HEAVY NAPHTHENIC
CAS:64742-52-5
RTECS #:PY8035001
Fraction by Wt: 45%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICON CARBIDE
CAS:409-21-2
RTECS #:VW0450000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:FATTY ACIDS; (FATTY ACIDS, TALLOW, CALCIUM SALTS)
CAS:64855-01-7
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICA GEL
CAS:112945-52-5
RTECS #:VV7310000
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE:MILDLY IRRITATING. SKIN:MILD
IRRITANT. PROLONGED CONTACT MAY CAUSE DEFATTING & REDNESS.
INHALATION:IF LIQUID PARTICLES ARE BREATHED INTO LUNGS, THEY MAY BE
RAPIDLY ABSORBED THROUGH LUNGS & I NJURE LIVER & KIDNEY/OTHER BODY
SYSTEMS. VAPORS AND/OR AEROSOLS WHICH MAY BE FORMED AT ELEVATED
TEMPS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:MAY BE IRRITATING. INGESTION:MAY CAUSE
NAUSEA AND VOMITING.
Medical Cond Aggravated by Exposure:PREEXISTING PULMONARY AND
DERMATOLOGICAL DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO HAZARDOUS
COMPONENTS.
======================= First Aid Measures =======================
First Aid:EYE:IMMED FLUSH W/PLENTY OF WATER FOR @ LEAST 15 MINS. GET
MED ATTN, IF IRRIT PERSISTS. SKIN:WASH W/SOAP & WATER. GET MED ATTN
IF IRRIT DEVELOPS/PERSISTS. INHAL:IF EXPOS TO EXCESS LEV OF
DUST/FUMES, R EMOVE TO FRESH AIR & GET MED ATTN IF COUGH/OTHER
SYMPS DEVELOP. INGEST:DO NOT INDUCE VOMIT. GIVE VICTIM GLASS OF
WATER/MILK. CALL PHYS/POIS CTL CTR IMMED. NEVER GIVE ANYTHING BY
MOUTH TO UNCON PERSON.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:400F,204C
Lower Limits:1.0%
Upper Limits:6.0%
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP . USE
WATER TO COOL EXPOSED CNTNRS. WATER STREAM DIRECTED INTO FIRE MAY
CAUSE FROTHING W/SUBSEQUENT (SUPDAT)
Unusual Fire/Explosion Hazard:CLSD CNTNRS MAY RUPTURE/EXPLODE (DUE TO
PRESS BUILD-UP) WHEN EXPOSED TO EXTREME HEAT. IRRITATING AND/OR
TOXIC GASES OR FUMES MAY BE GENERATED BY THERMAL(SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:RECLAIM CLEAN MATL. CONTAMD MATL SHOULD BE
SWEPT OR SHOVELED INTO APPROPRIATE WASTE CONTAINER & DISPOSED OF IN
ACCORDANCE WITH APPLICABLE FEDERAL, STATE AND LOCAL REGULATIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:HARMFUL IF SWALLOWED. AT ELEVATED
TEMPERATURES MAY CAUSE IRRIT OF EYES & RESP TRACT. AVOID
PRLNGD/RPTD CONTACT WITH SKIN. DO NOT TAKE INTERNALLY.
Other Precautions:FOR INDUSTRIAL USE ONLY. STORE AWAY FROM HEAT. KEEP
OUT OF THE REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQD UNDER GEN VENT. IF EXPOS LEV
ARE UNKNOWN, IF LEV EXCEED TLV/PEL, OR IF EFTS OCCUR, USE
NIOSH/MSHA APPRVD DUST/MIST RESP I/A/W APPLIC HLTH & SFTY REGS &
MFR'S RECOMMENDATIONS.
Ventilation:GENERAL VENTILATION USUALLY ADEQUATE.
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:FOLLOW GEN INDUST SFTY PRACTICES DURING USE. DO
NOT REUSE EMPTY CNTNRS W/OUT COMMERCIAL CLEAN/RECONDITION. (SUPDAT)
Supplemental Safety and Health
MFR TRADE NAME/PART NO:MIX-ALL GRADES. FIRE FIGHT PROC:SPREAD OF FLAME.
EXPLO HAZ:DECOMPOSITION OR COMBUSTION. HYGIENE PRAC:FOLLOW ALL
MSDS/LABEL PRECAUTIONS EVEN AFTER CONTAINER IS EMPTIED.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:650F,343C
Vapor Density:HVR/AIR
Spec Gravity:1.2063
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRAY PASTE, MILD OIL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:PROLONGED EXPOSURE TO HEAT.
Hazardous Decomposition Products:OXIDES OF CARBON. VARIOUS
HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:REVIEW ALL CURRENT FEDERAL, STATE, AND LOCAL
REGULATIONS REGARDING HEALTH AND DISPOSAL FOR APPROPRIATE DISPOSAL
PROCEDURES. INCINERATION PREFERRED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ENVI-RO-TECH PRECISION DUSTER 1668 OF
Preparer's Name:B RIFFEL
CAGE:DO677
CAGE:54700
CAGE:DO677
============= Composition/Information on Ingredients =============
Ingred Name:CHLORODIFLUOROMETHANE, FREON 22, MONOCHLORODIFLUOROMETHANE
CAS:75-45-6
RTECS #:PA6390000
Fraction by Wt: 100%
Other REC Limits:1000 PPM
OSHA PEL:1000 PPM
ACGIH TLV:3540 MG/CUM
Ozone Depleting Chemical:2
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: DIZZINESS, DROWSINESS, &
THROAT IRRITATION. EYES: IRRITATION W/SLIGHT TEMPORARY CORNEAL
INJURY. INGESTION: LOW TO MODERATE TOXICITY. SKIN: FREEZING OF
TISSUE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: UNCONSCIOUSNESS, BLOOD PRESSURE
DEPRESSION, CARDIAC SENSITIZATION, VENTRICULAR ARRHYTHMIA & DEATH.
SKIN: FREEZING OF TISSUES, DEFATTING & DERMATITIS. INGESTION:
ASPIRATION HAZARD, WHICH CA N CAUSE CHEMICAL PNEUMONIA & SYSTEMIC
EFFECTS. HUMAN PSYCHOTROPIC, GASTROINTESTINAL & CNS EFFECTS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING HAS STOPPED,
ADMINISTER ARTIFICIAL RESPIRATION. EYES: FLUSH W/CLEAR WATER FOR AT
LEAST 15 MINS. SKIN: WASH W/SOAP & WATER. FOR FROSTBITE, SEEK
MEDICAL ATT N. INGESTION: DON'T INDUCE VOMITING. GIVE 2 GLASSES OF
WATER. NOTE: ADRENALIN & OTHER SIMILAR CARDIAC STIMULANTS SHOULD
NOT BE USED TO TREAT EFFECTS OF OVEREXPOSURE. OBTAIN MED ATTN IN
ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Extinguishing Media:WATER, FOAM, DRY CHEMICAL, CO2
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR SELF CONTAINED
BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:AEROSOL CANS MAY ERUPT W/FORCE AT
TEMPERATURES >120F.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE & VENTILATE AREA. PICK UP LIQUID ON
SUITABLE ABSORBENT & STORE IN SEALED CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AEROSOL CANS IN COOL PLACE OUT OF
DIRECT SUNLIGHT. KEEP THIS & ALL CHEMICALS OUT OF REACH OF
CHILDREN. THIS PRODUCT IS FOR INDUSTRIAL USE ONLY.
Other Precautions:DON'T USE IN CLOSED SPACE. AVOID BREATHING VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF LEVELS EXCEED TLVS, INCREASED VENTILATION OR
ORGANIC VAPOR MASK REQUIRED.
Ventilation:REQUIRED
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:-41C/-41F
Vapor Density:3
Spec Gravity:1.194
pH:7-8
Evaporation Rate & Reference:(WATER = 1): >1
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR WATER-WHITE LIQUID W/LOW ODOR.
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTIVE ALKALI METALS, STRONG ACIDS & BASES
Stability Condition to Avoid:OPEN FLAME, HEAT, TEMPS >120F
Hazardous Decomposition Products:HYDROGEN CHLORIDE, PHOSGENE, CHLORINE,
CO2 & CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF BY A LICENSED RECLAIMER OR
INCINERATOR FACILITY. CONSULT LOCAL, STATE & FEDERAL DISPOSAL
AUTHORITIES FOR APPROVED PROCEDURES. DON'T INCINERATE OR DESTROY
AEROSOL CANS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:2-IODOPROPANE, O-647
CAGE:84898
CAGE:84898
CAGE:8Y898
============= Composition/Information on Ingredients =============
Ingred Name:PROPANE, 2-IODO-; (2-IODOPROPANE)
CAS:75-30-9
RTECS #:TZ4200000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (RAT) 1190 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ALL CHEMICALS SHOULD BE CONSIDERED
HAZARDOUS - AVOID DIRECT PHYSICAL CONTACT! CAN BE HARMFUL IF
ABSORBED THROUGH THE SKIN. CAN BE HARMFUL IF INHALED.
LACHRYMATOR-CAUSES SEVERE EYE IRRITATION. CAN CAUS E SKIN
IRRITATION. SUSPECTED CARCINOGEN-MAY PRODUCE CANCER. CAN CAUSE EYE
IRRITATION. CAN BE HARMFUL (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: IF SWALLOWED. CAN BE IRRITATING TO
MUCOUS MEMBRANES. PROLONGED EXPOSURE MAY CAUSE
NAUSEA/HEADACHE/DIZZINESS AND/OR EYE DAMAGE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:ANTIDOTE IS SUBSTANCE INTENDED TO COUNTERACT EFT OF POISON.
IT SHOULD BE ADMIN ONLY BY MD/TRAINED EMER PERS. MED ADVICE CAN BE
OBTAINED FROM POIS CTL CTR. EYES:FLUSH CONTINUOUSLY W/WATER FOR AT
LEAST 15-20 MIN. SKIN: FLUSH W/WATER FOR 15-20 MIN. IF NO BURNS
HAVE OCCURRED-USE SOAP & WATER TO CLEANSE SKIN. INHAL: REMOVE TO
FRESH AIR. ADMIN OXYGEN IF HAVING DFCLTY BRTHG. IF BRTHG HAS
STOPPED (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:108F,42C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER OR WATER SPRAY.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THIS IS A COMBUSTIBLE COMPOUND.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR APPROPRIATE OSHA-REGULATED
EQUIPMENT. VENTILATE AREA. ABSORB ON VERMICULITE OR SIMILAR
MATERIAL. SWEEP UP AND PLACE IN AN APPROPRIATE CONTAINER. HOLD FOR
DISPOSAL. WASH CONTAMINATE D SURFACES TO REMOVE ANY RESIDUES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH SKIN, EYES AND
CLOTHING. KEEP TIGHTLY CLOSED AND STORE IN A COOL, DRY PLACE. STORE
ONLY WITH COMPATIBLE CHEMICALS.
Other Precautions:PERSONS NOT SPECIFICALLY & PROPERLY TRAINED SHOULD
NOT HANDLE THIS CHEM OR ITS CNTNR. THIS PROD IS FURNISHED FOR LAB
USE ONLY! PRODS MAY NOT BE USED AS DRUGS, COSMETICS,
AGRICULTURAL/PESTICIDAL PRODS, FOOD ADDITIVES OR AS HOUSEHOLD
CHEMS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:THIS CHEMICAL SHOULD BE HANDLED ONLY IN A HOOD.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER . USE
APPROPRIATE OSHA/MSHA APPROVED SAFETY EQUIPMENT.
Work Hygienic Practices:CONTACT LENSES SHOULD NOT BE WORN IN THE
LABORATORY.
Supplemental Safety and Health
FIRST AID PROC: ADMIN ARTF RESP. IF IN CARD ARREST ADMIN CPR. CONTINUE
LIFE SUPPORTING MEASURES UNTIL MED ASSISTANCE HAS ARRIVED.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:194F,90C
Melt/Freeze Pt:M.P/F.P Text:-130F,-90C
Spec Gravity:1.703
Solubility in Water:INSOL (IMMISCIBLE)
Appearance and Odor:COLORLESS LIQUID; ETHER LIKE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE WITH STRONG BASES. INCOMPATIBLE WITH STRONG OXIDIZING
AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:DECOMPOSITION LIBERATES TOXIC FUMES.
DECOMPOSITION PRODUCTS ARE CORROSIVE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS . BURN IN A CHEMICAL INCINERATOR
EQUIPPED WITH AN AFTERBURNER AND SCRUBBER.
| 1 | gloves_mandatory |
=======================================================
Product ID: CONTAX-BULK, 95372
Cage: 18399
=======================================================
Contractor Summary
=======================================================
Cage: 18399
=======================================================
Ingredients
=======================================================
Cas: 142-82-5
RTECS #: MI7700000
% Wt: 60-65
OSHA PEL: 500 PPM
ACGIH TLV: 400 PPM; 500 STEL
------------------------------
Cas: 110-82-7
RTECS #: GU6300000
% Wt: 8-13
OSHA PEL: 300 PPM
ACGIH TLV: 300 PPM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 64-17-5
RTECS #: KQ6300000
% Wt: 10-15
OSHA PEL: 1000 PPM
ACGIH TLV: 1000 PPM
------------------------------
Cas: 67-63-0
RTECS #: NT8050000
MG/KG.
% Wt: 10-15
OSHA PEL: 400 PPM
ACGIH TLV: 400 PPM; 500 STEL
------------------------------
RTECS #: 9999999VO
N/A; % VOC: 100.
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: SEE INGREDIENTS
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: CAUSES EYE AND SKIN IRRITATION. INHALATION CAUSES ACUTE
IRRITATION OR EFFECTS TO RESPIRATORY SYSTEM. EXCESS INHALATION MAY CAUSE
DIZZINESS, GIDDINESS AND NAUSEA. MISUSE OR DELLIBERATE INHALATION MAY B E
HARMFUL OR FATAL. REPEATED AND PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE
PERMANENT DAMAGE TO (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ: CENTRAL NERVOUS SYSTEM AND
POSSIBLE CUMULATIVE OR IRREVERSIBLE EFFECTS TO LIVER AND URINARY SYSTEMS.
INGESTION CAUSES NAUSEA, CRAMPS, VOMITING, DIARRHEA OR ACUTE EFFECTS TO
LIVER, KDINEYS, B RAIN AND HEART.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES
AND CALL MD. SKIN: WASH THOROUGHLY WITH PLENTY OF SOAP AND WATER. INHALATION:
IF AFFECTED, REMOVE TO FRESH AIR. ADMINISTER OXYGEN A ND CALL MD. INGESTION:
SEEK MD IMMEDIATELY. SHOW MSDS OR LABEL. DO NOT INDUCE VOMITING.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION. VENTILATE AREA. WEAR
ABSORBENT MATERIAL. CONTAIN AND PICK UP WASTE MATERIALS. PUT IN A SEALE D
APPROVED CONTAINER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF WASTES IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS. DO NOT PUNCTURE, INCINERATE OR BURN CONTAINERS. DO NOT
EMPTY INTO DRAINS.
Handling And Storage Precautions: KEEP AWAY FROM HEAT, SPARKS, FLAME OR
IGNITION SOURCES. USE ONLY IN WELL VENTILATED AREAS. DO NOT BREATHE VAPOR OR
SPRAY MIST. AVOID CONTACT (SUPDAT)
Other Precautions: KEEP OUT OF REACH OF CHILDREN. ALWAYS READ AND FOLLOW
DIRECTIONS ON PRODUCT LABEL. ADDITIONAL TECHNICAL DATA SHEETS AND/OR MATERIAL
SAFETY DATA SHEETS (MSDS) AVAILABLE UPON REQUEST. FOR PROFESSIONAL A ND
INDUSTRIAL USE ONLY.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: -4F,-20C
Lower Limits: 1.1%
Upper Limits: 19.0%
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT
(FP N).
Unusual Fire/Explosion Hazard: EXPOSURE TO FIRE, HEAT OR PROLONGED SUNLIGHT MAY
CAUSE BURSTING. CONTACT WITH FLAMES OR HOT SURFACES MAY PRODUCE TOXIC GASES.
COMBUSTION PRODUCTS: CO, CO*2.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF VENTILATION IS INADEQUATE, WEAR NIOSH APPROVED
RESPIRATORY EQUIPMENT.
Ventilation: LOCAL AND MECHANICAL RECOMMENDED. KEEP AWAY FROM HEAT/FLAME.
Other Protective Equipment: ANSI APPROVED EYE WASH & DELUGE SHOWER (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: HNDLG/STOR PRECS: WITH EYES, SKIN AND CLOTHING.
WASH THOROUGHLY AFTER USING. DO NOT TAKE INTERNALLY. IN CASE OF ACCIDENT OR
ILLNESS, SEEK MD IMMEDIATELY. TAKE LABEL OR MSDS.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 172F,78C
M.P/F.P Text: -128F,-89C
Vapor Pres: 45
Vapor Density: 1.6
Spec Gravity: 0.716
Evaporation Rate & Reference: SLOWER THAN ETHER
Solubility in Water: 26%
Appearance and Odor: CLEAR LIQUID WITH HYDROCARBON ODOR.
Percent Volatiles by Volume: 100
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NO.
Hazardous Decomposition Products: CARBON DIOXIDE, CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: CONTAX-BULK, 95372
Cage: 18399
Company Name: PREMIER FARNELL CORPORATION
Street: 4500 EUCLID AVENUE
Zipcode: 44103-3736
Label Required IND: Y
Date Of Label Review: 03/18/1998
Status Code: C
Label Date: 03/18/1998
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE. ACUTE: CAUSES EYE AND SKIN IRRITATION.
INHALATION CAUSES ACUTE IRRITATION OR EFFECTS TO RESPIRATORY SYSTEM. EXCESS
INHALATION MAY CAUSE DIZZINESS, GIDDINESS AND NAUSEA. INGESTION CAUSES NAU
SEA, CRAMPS, VOMITING, DIARRHEA OR ACUTE EFFECTS TO LIVER, KIDNEYS, BRAIN AND
HEART. CHRONIC: MISUSE OR DELLIBERATE INHALATION MAY BE HARMFUL OR FATAL.
REPEATED AND PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT DAMAGE
TO CENTRAL NERVOUS SYSTEM AND POSSIBLE CUMULATIVE ORIRREVERSIBLE EFFECTS TO
LIVER AND URINARY SYSTEMS.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:INSTA-NEG DEVELOPER
CAGE:63763
CAGE:63763
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:C, 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:INFORMATION WITHHELD AS A TRADE SECRET.
Fraction by Wt: 95%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN IRRITATION, ALLERGIC REACTIONS,
THROAT BURNS AND EYE IRRITATIONS.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:AGGRAVATION OF PRESENT SKIN
CONDITION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MIN. INCLUDING UNDER EYELIDS.
SKIN: WASH AND RINSE WITH PLENTY OF WATER. USE NON-ALKALINE HAND
CLEANER TO MINIMIZE THE POSSIBILITY OF ALLERGIC SKIN REACTION.
INGESTION: G IVE PLENTY OF WATER AND INDUCE VOMITING.GET MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>200F,>93C
================== Accidental Release Measures ==================
Spill Release Procedures:NEUTRALIZE USING SODIUM BISULFATE AND MOP UP.
IF ALLOWED BY LAW, FLUSH INTO SEWER WITH LARGE AMOUNTS OF WATER.
Neutralizing Agent:SODIUM BISULFATE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN DRY, WELL VENTILATED AREA
SEPERATE FROM ACIDS. ABUNDANT WATER SUPPLY SHOULD BE NEARBY.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE.
================== Physical/Chemical Properties ==================
HCC:B1
Boiling Pt:=101.1C, 214.F
B.P. Text:214F,101C
Vapor Pres:17
Vapor Density:<1
Spec Gravity:1.1420
pH:12.7
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:100
Appearance and Odor:CLEAR TO SLIGHTLY AMBER AND RELATIVELY ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MINERAL ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:SULFUR DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FERROSILICON, ESCALLOY
CAGE:0LNE8
CAGE:0NET8
CAGE:0LNE8
============= Composition/Information on Ingredients =============
Ingred Name:SILICON; (SI)
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: 45-85%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:IRON; (FE)
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: 15-55%
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:CHROMIUM (SARA 313) (CERCLA)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: <0.5%
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ALUMINUM (SARA 313)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 0.1-2.5%
OSHA PEL:15 MG/M3 DUST
ACGIH TLV:10 MG/M3 DUST
Ingred Name:CALCIUM (MFR CAS # 7440-90-2)
CAS:7440-70-2
RTECS #:EV8040000
Fraction by Wt: <2.0%
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:0.01 MG(AS)/M3
Ingred Name:GRAPHITE (C)
CAS:7782-42-5
RTECS #:MD9659600
Fraction by Wt: 25-35%
OSHA PEL:15 MPPCF; Z-3
ACGIH TLV:2 MG/M3 RDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: AIRBORNE DUST GENERATED THROUGH
THE USE OF THIS PRODUCT MAY RESULT IN RESPIRATORY AND/OR EYE
IRRITATION. AVOID PROLONGED EXPOSURE TO CONCENTRATIONS ABOVE
RECOMMENDED EXPOSURE LIMIT UNLESS PROTE CTIVE EQUIPMENT IS WORN.
CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:COUGHING, EYE IRRITATION, SNEEZING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: WASH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.
INHALATION: REMOVE VICTIM TO A WELL VENTILATED AREA. SKIN: FLUSH
WITH COPIOUS AMOUNTS OF WATER. SEE MD . INGESTION: CALL MD
IMMEDIATELY ( ).
===================== Fire Fighting Measures =====================
Extinguishing Media:CLASS D FIRES. USE DRY CHEMICAL, SAND OR CARBON
DIOXIDE TO SMOTHER FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. FIRE MAY BE ISOLATED AND ALLOWED TO BURN ITSELF OUT. DO NOT
DISTURB BURNING METAL WHILE EXTING FIRE.
Unusual Fire/Explosion Hazard:LUMP ALLOY IS NOT FLAMMABLE. VERY FINE
DUST (MINUS 200 MESH) MAY PRESENT AN EXPLOSION HAZARD WHEN
AIRBORNE. DANGEROUS WHEN WET.
================== Accidental Release Measures ==================
Spill Release Procedures:NO SPECIAL PRECAUTIONS REQUIRED EXCEPT KEEP
DRY. SWEEP UP IN NORMAL MANNER FOR REUSE OR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP MATERIAL DRY WHEN STORING FOR
EXTENDED PERIODS. INERT ATMOSPHERE ADVISED WHEN SIZING TO -200 MESH
OR LOWER.
Other Precautions:GRINDING WET MATERIAL MAY BE HAZARDOUS DUE TO
POSSIBLE HYDROGEN EVOLUTION. ANY WET MATERIAL IN CONTACT WITH
MOLTEN METAL MAY CAUSE AN ERUPTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN DUSTY AREAS (WHERE RECOMMENDED EXPOSURE
LIMITS ARE EXCEEDED) USE A NIOSH/MSHA APPROVED SCHEDULE 21C
RESPIRATOR.
Ventilation:LOCAL EXHAUST REQUIRED IN PROCESSING AREAS. FOLLOW LOCAL
WORK RULES.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MP: >2192F, >1250C.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:SUP DAT
Spec Gravity:2-4 (H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:METALLIC GREY COLOR, NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTS RAPIDLY IN HYDROFLUORIC/NITRIC ACIDS AS WELL AS MOLTEN ALKALI.
Stability Condition to Avoid:STABLE AS LUMP & WHEN DRY. WHEN FINE
SIZED, AVOID CONTACT WITH MOISTURE. AVOID CONTACT WITH HALOGEN
ACIDS.
Hazardous Decomposition Products:SMALL AMOUNTS OF ARSINE, PHOSPHINE,
AND HYDROGEN MAY EVOLVE IF MOISTURE IS PRESENT.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS. DO NOT STORE IN SEALED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TT-P-1952D, TY I, WHITE 700W47
Preparer's Name:ROBERT COMMISSO
CAGE:DO312
CAGE:58963
CAGE:DO312
============= Composition/Information on Ingredients =============
Ingred Name:ACRYLIC POLYMER PLUS PROPRIETARY ADDITIVES
Fraction by Wt: 25%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:METHANOL (SARA 313) (CERCLA) (VAPOR PRESSURE 5.9 MM HG @
68F)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VOC: 0.37 LB/GL (44 G/L)
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN, NOSE, THROAT, AND RESPIRATORY
IRRITATION MAY RESULT FROM OVEREXPOSURE.
Effects of Overexposure:INHALATION: IRRITATION OF NOSE, THROAT &
RESPIRATORY TRACT. HEADACHES & NAUSEA MAY ALSO OCCUR. SKIN & EYE:
PROLONGED OR REPEATED CONTACT MAY CAUSE SKIN IRRITATION. DIRECT
CONTACT MAY RESULT IN EYE IR RITATION. INGESTION: INGESTION MAY
CAUSE IRRITATION AND DAMAGE TO MUCOUS MEMBRANES.
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR & GIVE ARTIFICIAL RESPIRATION
OR OXYGEN IF NEEDED. CALL A PHYSICIAN. INGESTION: DO NOT INDUCE
VOMITING. CALL A PHYSICIAN. EYE CONTACT: FLUSH EYES WITH WATER FOR
15 MINU TES. CALL A PHYSICIAN. SKIN CONTACT: WASH SKIN WITH SOAP
AND WATER. CALL A PHYSICIAN. SKIN CONTACT: WASH SKIN WITH SOAP AND
WATER. CALL A PHYSICIAN IF IRRITATION PERSISTS.
===================== Fire Fighting Measures =====================
Autoignition Temp:Autoignition Temp Text:775 F
Lower Limits:7.3
Extinguishing Media:NONE KNOWN. * 9.5
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:PRODUCT WILL NOT BURN BUT MAY SPATTER IF
TEMPERATURE EXCEEDS BOILING POINT. POLYMER FILMS ARE CAPABLE OF
BURNING, GIVING OFF OXIDES OF CARBON/NITROGEN.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. DIKE AND
CONTAIN SPILL WITH INERT MATERIAL. TRANSFER LIQUID TO CONTAINERS.
KEEP SPILLS AND RUNOFFS OUT OF MUNICIPAL SEWERS AND OPEN BODIES OF
WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID FREEZING. AVOID CONTACT WITH
MICROORGANISMS. KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:CAUTION - MAY BE HARMFUL IF SWALLOWED. BREATHING
VAPOR OR MIST MAY BE HARMFUL. USE WITH ADEQUATE VENTILATION. AVOID
EYE AND SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURE EXCEEDS PERMISSIBLE EXPOSURE LIMITS,
USE APPROPRIATE NIOSH APPROVED RESPIRATORY EQUIPMENT.
Ventilation:LOCAL EXHAUST RECOMMENDED. MECHANICAL VENTILATION
RECOMMENDED.
Other Protective Equipment:EYE WASH FOUNTAIN, SAFETY SHOWER
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:147 TO 212F
Vapor Density:> AIR
Spec Gravity:1.7 (WATER=1)
pH:9.2- *
Viscosity:80 - 90 KU
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:100%
Appearance and Odor:BLUE VISCOUS LIQUID WITH SLIGHT AMMONIA ODOR
Percent Volatiles by Volume:37.9
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:FREEZING TEMPERATURES
Hazardous Decomposition Products:NONE KNOWN
Conditions to Avoid Polymerization:FREEZING TEMPERATURES
==================== Disposal Considerations ====================
Waste Disposal Methods:OBEY RELEVANT LOCAL, STATE, AND FEDERAL LAWS. DO
NOT CONTAMINATE ANY LAKES, PONDS, STREAMS, OR UNDERGROUND WATER
SUPPLIES. TREAT AS HAZARDOUS WASTE. DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE, AND L OCAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: CHEMSEARCH 777, 0424
Cage: DO481
Box: 152170
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: DO481
Box: 152170
Cage: 20913
Box: 152170
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: SEE INGREDIENTS
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: MODERATE IRRITANT PARTICULARLY TO WET SKIN. CAN
CAUSE IRRITATION TO EYES. CHRONIC: MARKED IRRITATION TO SKIN AND EYES.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL: GET OUT OF CONTAMD AREA TO FRESH AIR. IF BRTHG HAS STOPPED,
ARTF RESP SHOULD BE STARTED. O*2 MAY BE ADMIN IF AVAIL. SEEK MED ATTN IMMED.
EYES: IMMED FLUSH W/LG AMTS WATER FOR @ LEAST 15 MIN HOL DING LIDS APART FOR
MAXIMUM FLUSHING. SEEK MED ATTN IF IRRIT PERSISTS. TREATMENT IS MOST EFTIVE
IN FIRST MIN. SKIN: WASH CONTAMD AREAS W/SOAP & WATER. REMOVE CONTAMD
CLTHG & FOOTWEAR & WASH (SUPDAT)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: STOP LEAKS. CONTAIN SPILL. REMOVE AS MUCH AS POSS.
NEUTRALIZE REMAINING TRACES OF MATL W/DILUTED ACID; THEN FLUSH AREA W/WATER.
REUSE SPILLED MATL, IF POSS, OTHERWISE PLACE IN CLSD, LABELED CNTNR & ST
ORE IN SAFE PLACE TO AWAIT PROPER DISPOSAL.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: PERSONS PERFORMING WORK WHOULD WEAR ADEQ PERSONAL PROT
EQUIP & CLTHG. DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE & LOCAL
REGS CONCERNING HEALTH & POLLUTION. DISPOSE VIA APPROVED CHEMICAL WASTE
DISPO SAL METHOD IF REGS PERMIT.
Handling And Storage Precautions: STORE AT MODERATE TEMPERATURES, BETWEEN
35F-150F. AVOID SKIN OR EYE CONTACT.
Other Precautions: KEEP OUT OF REACH OF CHILDREN. READ AND FOLLOW ALL LABEL
DIRECTIONS. STORE ONLY IN LABELED CONTAINER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: NONE
Extinguishing Media: FOAM, ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER
SPRAY.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N). PRODUCT IS NON-FLAMMABLE. EXTINGUISHING MEDIA ARE DEPENDENT
ON NATURE OF PRODUCT.
Unusual Fire/Explosion Hazard: SODIUM NITRITE EXPLODES WHEN HEATED OVER 1000F
OR ON CONTACT WITH CYANIDES, AMMONIUM SALTS, CELLULOSE, LITHIUM, SODIUM
THISOULFATE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH/MSHA APPROVED MASK IF MISTING OCCURS.
Ventilation: MECHANICAL (GENERAL) VENTILATION IS USUALLY ADEQUATE.
Other Protective Equipment: APRON SHOULD BE WORN DEPENDING ON SEVERITY OF
EXPOSURE.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: FIRST AID PROC: BEFORE REUSE. SEE MD IF IRRIT
PERSISTS. INGEST: SEEK MED ATTN IMMED. GIVE LG QTYS WATER & INDUCE VOMIT.
KEEP AIR PASSAGES CLEAR. NEVER GIVE ANYTHING BY MOUTH TO UNCON PERSON. SEEK
MED ATTN IMMED.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 220F,104C
Vapor Pres: 15
Vapor Density: 0.6
Spec Gravity: 1.10 (H*2O=1)
PH: 11.6
Evaporation Rate & Reference: 0.10 (BU AC =1)
Solubility in Water: COMPLETE
Appearance and Odor: PURPLE; ODORLESS.
Percent Volatiles by Volume: 89
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: CYANIDES, REDUCING AGENTS, COMBUSTIBLE MATERIALS, AMMONIUM
SALTS AND THIOSULFATES.
Hazardous Decomposition Products: SILICA, SODIUM OXIDES AND OXIDES OF NITROGEN.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: CHEMSEARCH 777, 0424
Cage: DO481
Assigned IND: Y
Company Name: NATIONAL CHEMSEARCH DIV OF NCH CORP
Street: 2727 CHEMSEARCH BLVD
PO Box: 152170
Zipcode: 75015-5000
Label Required IND: Y
Date Of Label Review: 07/26/1994
Status Code: C
Label Date: 07/26/1994
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: MODERATE IRRITANT PARTICULARLY TO WET SKIN. CAN
CAUSE IRRITATION TO EYES. CHRONIC: MARKED IRRITATION TO SKIN AND EYES.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SPS 5070, SIFCO SELECTRON PLATING SOLUTION CADMIUM LHE
Resp. Party Other MSDS Num.:SPS 5070
CAGE:11924
Contract Num:SP0450-01-M-ZB15
CAGE:11924
============= Composition/Information on Ingredients =============
Ingred Name:CADMIUM FLUOBORATE
CAS:14486-19-2
RTECS #:EV0525000
Minumum % Wt:15.
Maxumum % Wt:25.
Other REC Limits:9 MG/M3 (IDLH,NIOSH)
OSHA PEL:0.005 MG/M3 (CD)
ACGIH TLV:0.002MG/M3(CD,RDUST)
Ingred Name:ETHYLENEDIAMINE
CAS:107-15-3
RTECS #:KH8575000
Minumum % Wt:15.
Maxumum % Wt:25.
OSHA PEL:25 MG/M3;10 PPM
ACGIH TLV:25 MG/M3;10 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Minumum % Wt:50.
Maxumum % Wt:70.
===================== Hazards Identification =====================
LD50 LC50 Mixture:NO DATA PROVIDED BY MANUFACTURER
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:TARGET ORGANS: SKIN, EYES, NASAL
CAVITY, LUNGS, KIDNEYS & LIVER. EYE: CAUSES EYE IRRITATION, BURNS
POSSIBLE. SKIN CONTACT: CAUSES SKIN IRRITATION, MAY CAUSE BURNS &
POSSIBLE ALLERGIC REACTION. INHALAT ION: MAY CAUSE SNEEZING, NASAL
DISCHARGE, COUGHING, HEADACHES, DIZZINESS, NAUSEA, FATIGUE OR
DIFFICULTY IN BREATHING. MAY CAUSE SENSITIZATION OF RESPIRATORY
TRACT. INGESTION: IRRITATING TO MOUTH, THRO AT, AND STOMACH. MAY
CAUSE LIVER DAMAGE WITH JAUNDICE, KIDNEY & GASTROINTESTINAL DAMAGE.
CHRONIC EFFECTS: PROLONGED OR REPEATED EXPOSURE MAY CAUSE DAMAGE TO
SKIN, EYES, RESPIRATORY SYSTEM AND TEETH. M AY CAUSE SEVERE &
DELAYED HEALTH EFFECTS
Explanation of Carcinogenicity:NO DATA PROVIDED BY MANUFACTURER
Effects of Overexposure:EYE: EYE IRRITATION, BURNS. SKIN CONTACT: SKIN
IRRITATION, BURNS AND POSSIBLE ALLERGIC REACTION. INHALATION:
SNEEZING, NASAL DISCHARGE, COUGHING, HEADACHES, DIZZINESS, NAUSEA,
FATIGUE OR DIFFICULTY IN BREATHING, SENSITIZATION OF RESPIRATORY
TRACT. INGESTION: IRRITATING TO MOUTH, THROAT & STOMACH. MAY CAUSE
LIVER DAMAGE WITH JAUNDICE, KIDNEY & GASTROINTESTINAL DAMAGE.
CHRONIC EFFECTS: DAMAGE TO SKI N, EYES, RESPIRATORY SYSTEM & TEETH.
INFLAMMATION OF LUNGS & CHEMICAL BRONCHITIS. POSSIBLE PROSTATE
CANCER.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN AND EYE
CONDITIONS; RESPIRATORY SYSTEM DISORDERS.
======================= First Aid Measures =======================
First Aid:EYES: HOLD LIDS APART & FLUSH WITH PLENTY OF WATER FOR AT
LEAST 15 MINUTES. SKIN: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR
AT LEAST 15 MINUTES WHILE REMOVING CONTAMINATED CLOTHING & SHOES.
THOROUGHL Y DECONTAMINATE OR DISCARD CLOTHING & SHOES. INHALATION:
REMOVE TO FRESH AIR. LAY VICTIM DOWN, LEGS RAISED. LOOSEN TIGHT
CLOTHING, COVER WITH A BLANKET. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN. INGESTION: DO
NOT INDUCE VOMITING, UNLESS ADVISED BY EMS. GIVE VICTIM LOTS OF
WATER/MILK WITH 1-2 EGGS.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:N.A.
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:ALL
Fire Fighting Procedures:NIOSH/MSHA APPROVED POSITIVE-PRESSURE
SELF-CONTAINED BREATHING APPARATUS. STRUCTURAL FIRE FIGHTERS'
PROTECTIVE CLOTHING MAY NOT PROVIDE ADEQUATE PROTECTION.
Unusual Fire/Explosion Hazard:CONTAINERS CAN BUILD UP PRESSURE AND
BURST IF EXPOSED TO HEAT (FIRE). WATER RUNOFF CAN CAUSE
ENVIRONMENTAL DAMAGE. DIKE AREA FOR LATER DISPOSAL. NFPA 704M
SYSTEM: HEALTH-3, FLAMMABILITY-0, REACTIVITY- 0.
================== Accidental Release Measures ==================
Spill Release Procedures:DO NOT TOUCH OR WALK THROUGH SPILLED MATERIAL.
ISOLATE HAZARD AREA AND KEEP PEOPLE AWAY. NOTIFY YOUR FACILITY
EMERGENCY COORDINATOR. ELIMINATE ALL SOURCES OF IGNITION. PROVIDE
MAXIMUM VENTILATION. DO NOT RELEASE INTO SOIL, SEWERS, OR NATURAL
BODIES OF WATER. WEAR PROPER PERSONAL PROTECTIVE EQUIP,ENT (PPE).
CAREFULLY MOP UP OR VACUUM SPILL AND TRIPLE RINSE WITH WATER INTO
SUITABLE PLASTIC CONTAINER
Neutralizing Agent:N.A
======================Handling and Storage ======================
Handling and Storage Precautions:USE "BUDDY SYSTEM' WHEN WORKING WITH
CHEMICALS. DO NOT GET IN EYES, ON SKIN, ON CLOTHING. DO NOT BREATHE
VAPOR, MIST OR GAS. USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY
AFTER HANDLING. TRIPLE RINSE CONTAINER CLEAN BEFORE DISCARDING.
PUT NOTHING ELSE IN THIS CONTAINER.
Other Precautions:KEEP CONTAINER TIGHTLY CLOSED IN UPRIGHT POSITION.
STORE 60-90 AWAY FROM INCOMPATIBLE MATERIALS & PHYSICAL HAZARDS. DO
NOT REMOVE OR DEFACE CONTAINER LABELS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS ARE NOT FEASIBLE, THE
RESPIRATORY PROTECTION PROGRAM MUST COMPLY WITH OSHA 29 CFR
1910.134.
Ventilation:LOCAL EXHAUST VENTILATION IS REQUIRED TO MEET THE
PERMISSIBLE EXPOSURE LIMITS (PEL) DURING THE USE OF THIS PRODUCT.
Other Protective Equipment:IMPERVIOUS BOOTS, APRON, PROTECTIVE CLOTHING
AS REQUIRED BY JOB CONDITIONS. EYE WASH STATION, SAFETY SHOWER,
WASHING FACILITIES NEAR WORK AREA.
Work Hygienic Practices:DO NOT WEAR CONTACT LENSES. WASH THOROUGHLY
AFTER HANDLING.
Supplemental Safety and Health
NO DATA PROVIDED BY MANUFACTURER
================== Physical/Chemical Properties ==================
HCC:B2
Boiling Pt:>100.C, 212.F
Melt/Freeze Pt:<0.C, 32.F
Spec Gravity:1.250 - 1.260
pH:7.5 - 7.9
Evaporation Rate & Reference:<1
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT YELLOW LIQUID; AMMONIACAL ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, OXIDIZERS.
Stability Condition to Avoid:STABLE UNDER NORMAL AMBIENT CONDITIONS.
Hazardous Decomposition Products:NOX, COX, F2, CD
=================== Toxicological Information===================
Toxicological Information:NOT AVAILABLE.
===================== Ecological Information =====================
Ecological:NOT AVAILABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:EPA WASTE I.D. NUMBER: D006. SHIP TO APPROVED
TREATMENT/DISPOSAL FACILITY. DISPOSE OF ACCORDING TO LOCAL, STATE,
AND FEDERAL REGULATIONS. FOLLOW THE APPLICABLE REGULATIONS FOR
DISPOSAL OF EMPTY CONTAI NERS AND RINSATE. THE DISPOSAL INFORMATION
APPLIES TO THE MATERIAL AS MANUFACTURED. CONTAMINATION MA Y AFFECT
THE DISPOSAL REQUIREMENTS.
=================== MSDS Transport Information ===================
Transport Information:DOT/IMO/IATA/ICAO DESCRIPTION: PROPER SHIPPING
NAME: CORROSIVE LIQUID, BASIC, N.O.S. (CONTAINS ETHYLENEDIAMINE,
CADMIUM FLUOROBORATE). HAZARD CLASS: 8. IDENTIFICATION NUMBER:
UN3267. PACKAGING GROUP ( PG): II. LABEL REQUIREMENTS: 8 -
CORROSIVE, MARINE POLLUTANT. UNIT CONTAINER: 1, 4, 20, 60 LITER
POLYETHYLENE CONTAINER. PACKAGING: MEETS PERFORMANCE ORIENTED
PACKAGING REQUIREMENTS. REPORTABLE QUANTI TY (RQ): >40 LITERS. ERG
GUIDE #: 153.
===================== Regulatory Information =====================
SARA Title III Information:THIS PRODUCT CONTAINS A TOXIC CHEMICAL OR
CHEMICALS SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF
TITLE III OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF
1986 AND 40 CFR PART 372, I F SPECIFIED ANNUAL THRESHOLDS ARE MET
OR EXCEEDED: CADMIUM COMPOUNDS (AS CD), CAS# 7440-43-9, 10% (WT %).
CERCLA/EPCRA: TPQ: >20,000 LITERS. (RELEASE) REPORTABLE QUANTITY:
>40 LITERS. EXTREMELY HAZAR DOUS SUBSTANCE: ETHYLENEDIAMINE. EPCRA
HAZARD CATEGORIES: IMMEDIATE (ACUTE) HEALTH: YES; DELAYED (CHRONIC)
HEALTH: YES, FIRE: NO, SUDDEN RELEASE OF PRESSURE: NO, REACTIVITY:
NO.
Federal Regulatory Information:TSCA: ALL INGREDIENTS OF THIS PRODUCT
ARE LISTED UNDER THE TOXIC SUBSTANCES CONTROLA CT (TSCA). ODS
CERTIFICATION: THIS PRODUCT DOES NOT CONTAIN AND IS NOT
MANUFACTURED WITH OZONE DEPLETING SUBSTANCES (ODS). VOC
CERTIFICATION: THIS PRODUCT DOES NOT CONTAIN ANY VOLATIEL ORGANIC
COMPOUNDS (VOC). PCB CERTIFICATION: THIS PRODUCT DOES NOT CONTAIN
ANY POLYCHLORINATED BUPHENYLS (PCB).
State Regulatory Information:CALIFORNIA PROPOSITION 65: WARNING! THIS
PRODUCT CONTAINS DETECTABLE AMOUNTS OF CHEMICALS KNOWN TO THE STATE
OF CALIFORNIA TO CAUSE CANCER, BIRTH DEFECTS OR OTHER REPRODUCTIVE
HARM.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:0410130 SULFACHLOROPYRIDAZINE 408-011/31325, 408-025/31326
CAGE:05545
CAGE:05545
CAGE:15481
============= Composition/Information on Ingredients =============
Ingred Name:SULFACHLOROPYRIDAZINE
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NONE
Medical Cond Aggravated by Exposure:INDIVIDUALS W/KNOWN/SUSPECTED
ALLERGIES TO ANTIBIOTICS SHOULD ADVISE PHYSICIAN OF INCIDENT THAT
MAY HAVE RESULTED IN EXPOSURE TO ANTIBIOTIC TREATED PRODUCT.
======================= First Aid Measures =======================
First Aid:OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:ANY EXTINGUISHING MEDIA USED DURING FIRE FIGHTING
WILL BE COMPATIBLE.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:MAY BE SWEPT UP & DISPOSED OF W/NORMAL LAB
TRASH.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER NORMAL PRODUCT USAGE.
Ventilation:NOT REQUIRED UNDER NORMAL PRODUCT USAGE
Other Protective Equipment:NOT REQUIRED UNDER NORMAL PRODUCT USAGE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:INSOLUBLE
Appearance and Odor:PAPER DISCS OF VARIABLE COLOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:MAY BE DISPOSED OF W/NORMAL LAB TRASH IAW/STATE,
LOCAL & FEDERAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:817 4658 EKTACOLOR RA 100 BLEACH-FIX REPLENISHER, PART A
Kit Part:Y
CAGE:5K871
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 70-75%
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMMONIUM THIOSULFATE
CAS:7783-18-8
RTECS #:XN6465000
Fraction by Wt: 20-25%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM BISULFITE (SASA III) (CERCLA)
CAS:7631-90-5
RTECS #:VZ2000000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:AMMONIUM BISULFITE (CERCLA)
CAS:10192-30-0
RTECS #:WT3595000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:AMMONIUM SULFITE (CERCLA)
CAS:10196-04-0
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:AMMONIUM ACETATE (CERCLA)
CAS:631-61-8
RTECS #:AF3675000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): NOT GIVEN
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. MAY LIBERATE SULFUR DIOXIDE GAS WHICH IS
IRRITATING TO THE RESPIRATORY TRACT. MAY CAUSE TRANSIENT EYE
IRRITATION. LOW SKIN CONTACT HAZA RD FOR RECOMMENDED HANDLING.
EXPECTED TO BE A LOW INGESTION HAZARD.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION, DIFFICULT BREATHING, WHEEZING,
CHEST TIGHTNESS, STOMACH UPSET, HIVES, FAINTNESS, WEAKNESS,
DIARRHEA.
Medical Cond Aggravated by Exposure:SOME ASTHMATICS OR HYPERSENSITIVE
INDIVIDUALS MAY EXPERIENCE DIFFICULT BREATHING, WHEEZING, CHEST
TIGHTNESS, STOMACH UPSET, HIVES, FAINTNESS, WEAKNESS, DIARRHEA.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMMEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:NONFLAMMABLE. USE EXTINGUISHING MEDIA SUITABLE FOR
SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER IF ALLOWABLE WITH LARGE AMOUNTS
OF WATER. OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT
MATERIAL, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN
SURFACE TO REMOVE RESIDUA L CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION. KEEP
FROM CONTACT WITH OXIDIZING MATERIALS. KEEP AWAY FROM INCOMPATIBLE
SUBSTANCES. KEEP CONTAINER CLOSED.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.17
pH:5.4
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID, AMMONIA ODOR
Percent Volatiles by Volume:70-75%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, STRONG OXIDIZING AGENTS, BASES, SODIUM HYPOCHLORITE
(BLEACH).
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
OXIDES OF NITROGEN, OXIDES OF SULFUR, AMMONIA.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. MAY REQUIRE NEUTRALIZATION IF PH
< 2.0 OR PH > 12.5. DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE ANDLOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:848 7555 EA-5 PREHARDENER AND REPLENISHER, WORKING SOLN
Kit Part:Y
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 75-80%
Other REC Limits:NONE RECOMMENDED
Ingred Name:MAGNESIUM SULFATE HEPTAHYDRATE
CAS:10034-99-8
RTECS #:OM4508000
Fraction by Wt: 10-15%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM SULFATE
CAS:7757-82-6
RTECS #:WE1650000
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM ACETATE
CAS:127-09-3
RTECS #:AJ4300010
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SUCCINADEHYDE-BIS-BISULFITE
CAS:5450-96-4
RTECS #:EK3585000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT ESTABLISHED.
ACGIH TLV:NOT ESTABLISHED.
Ingred Name:FORMALDEHYDE (SARA 302/313) (CERCLA)
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: 0.7%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE 1910.1048
ACGIH TLV:C 0.3 PPM, A2; 9495
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INHAL:FORMALDEHYDE DETECTABLE BY MOST
PEOPLE @LEVELS <1PPM.PRODUCES MILD SENSORY IRRIT OF EYE/NOSE/THROAT
@2-5PPM,BECOMES UNPLEASANT @5-10PPM,INTOLERABLE @HIGHER CONCEN.EXPO
TO FORMALDEHYDE CAUSE RESPSENS IN SOME PEOPLE. EYE:IRRIT.VAP
IRRIT,TEARING,TRANSIENT IRRIT. SKIN:IRRIT,ALLERGIC RX.
INGEST:EXPECTED TO BE LOW HAZ
Explanation of Carcinogenicity:PER MSDS:CARCINOGENIC PER
IARC/ACGIH/NTP/OSHA.
Effects of Overexposure:FORMALDEHYDE SYMPTOMS:MILD SENSORY IRRIT OF
EYES/NOSE/THROAT, UNPLEANSANT, INTOLERABLE. RESPIRATORY
SENSITIZATION. EYE IRRIT, TEARING, TRANSIENT IRRIT. SKIN IRRIT,
ALLERGIC SKIN REACTION.
Medical Cond Aggravated by Exposure:FORMALDEHYDE AGGRAVATE PRE-EXISTING
ASTHMATIC CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE TO FRESH AIR.TREAT SYMPTOMATICALLY.SYMPTOMS OCCUR
GET MED ATTN. EYE:IMMED FLUSH W/PLENTY OF WATER FOR @LEAST
15MINS.GET MED ATTN. SKIN:IMMED FLUSH W/PLENTY OF WATER FOR @LEAST
15MINS WHILE REMOVING CONTAMIN CLOTH/SHOES.SKIN IRRIT/ALLERGIC
SKIN RX DEVELOPS GET MED ATTN. INGEST:DRINK 1-2 GLASSES OF
WATER.SEEK MED ATTN.NEVER GIVE ANYTHING BY MOUTH IF UNCONSC.
===================== Fire Fighting Measures =====================
Flash Point:NONE,NON-COMBUST
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER W/LG AMTS OF WATER. OTHERWISE
ABSORB W/VERMICULITE OR OTHER INERT MATL, THEN PLACE IN CONTAINER
FOR CHEM WASTE. CLEAN SURFACE THOROUGHLY TO REMOVE RESIDUAL
CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATH VAP/CONTACT
W/EYE/SKIN/CLOTH.USE W/ADEQUATE VENTI.KEEP CNTNR CLSD.MATL
MODERATELY ACIDIC AQU SOLN.PROPTY:LOW BIOCHEM OXY DEMAND;(SUPPLEM)
Other Precautions:OSHA STD 29CFR1910.1048 SHOULD BE CONSULTED FOR SPEC
DETAILS REGARDING RESP/SKIN/EYE PROT AGAINST FORMALDEHYDE.STD ALSO
PROVIDES ESTABLISHING REG AREAS/RESP PROT PROGRAMS/HOUSEKPING/MED
SURVEILL,RECOR DKPING/WORKER INFO/TRAIN WHEN NECESSARY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FORMALDEHYDE EMITTED @LEVELS REQUIRING RESP PROT
WEAR:FULL FCPIECE W/CARTRIDGES/CANISTERS NIOSH APPROVE PROT AGAINST
FORMALDEHYDE/TYP C AIR-SUPPLIED RES DEMAND TYP W/FULL
FCPIECE/HOOD/HELMET.RESP USED INSTITUTE PRGRM IAW OSHA
29CFR1910.1048
Ventilation:USE GOOD GEN VENT(TYP 10AIR CHANGES/HR).MATCH VENT RATES
W/CONDITIONS.USE PROCESS ENCLSURE/LOC EXHAU VENT/OTH ENGR(SUPP)
Other Protective Equipment:PROTECTIVE CLOTHING APPROPRIATE FOR EXPO
RISK.EYEBATH,WASH FACILITIES,SAFETY SHOWER.
Work Hygienic Practices:WASH CONTAMIN CLOTH BEF
REUSE.DESTROY/THOROUGHLY CLEAN CONTAMIN SHOES.WASH WELL AFT
HANDLING.
Supplemental Safety and Health
PH:5.55-5.75. VENT:CNTRL TO MAINTAIN AIRBORNE LEVEL212F,>100C
Vapor Pres:18MM @20C
Vapor Density:0.6
Spec Gravity:1.18-120
pH:SUPPLE
Solubility in Water:COMPLETE.
Appearance and Odor:LIQUID, GREEN, STRONG ODOR.
Percent Volatiles by Volume:75-80
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE W/COMMON MATLS & CONTAMINANTS W/WHICH MATL MAY REASONABLY COME
INTO CONTACT.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:HAZ COMBUST PROD:NONE
(NON-COMBUSTIBLE).
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE/TREAT/DISPOSAL MAY BE SUBJECT TO
NAT/STATE/LOC LAWS.FLUSH TO SEWER W/LG AMTS OF WATER.CHEM SUBJ TO
SARA SEC 313 TITLE III & 40CFR PART 372:FORMALDEHYDE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:STYCAST U 2500 PART B
CAGE:B1152
CAGE:B1152
============= Composition/Information on Ingredients =============
Ingred Name:BENZENE, 1,1'-METHYLENEBIS(ISOCYANATO-;
(4,4'DIPHENYLMETHANE DIISOCYANATE, ISOMERES/HOMOLOGUES)
CAS:26447-40-5
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT) >5000 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITANT FOR SKIN, EYES & RESPIRATORY
SYSTEM. HARMFUL BY INHALATION. MAY CAUSE SENSITIZATION BY
INHALATION. EYE CONTACT:LACRIMATION, BURNING, CONSIDERABLE
IRRITATION OF OUTER EYE. SKIN CONTACT:MODERAT ELY IRRITATING.
DEHYDRATION. INHALATION:IRRITATION OF MUCOUS MEMBRANES IN NOSE,
THROAT AND LUNGS, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:DRYNESS OF THROAT, PRESSURE ON CHEST,
SOMETIMES BREATHING DIFFICULTIES AND HEADACHES. INGESTION:HARMFUL
IF SWALLOWED.
Medical Cond Aggravated by Exposure:DELAYED APPEARANCE OF SYMPTOMS &
ALLERGIC REACTION IN SUSCEPTIBLE PERSONS POSSIBLE.
======================= First Aid Measures =======================
First Aid:EYES:IRRIGATE IMMEDIATELY W/WATER FOR AT LEAST 15 MINUTES.
GET MEDICAL ATTENTION IMMEDIATELY. SKIN:WASH AFFECTED AREA W/PLENTY
OF WATER. GET MEDICAL ATTENTION IF IRRITATED. INHAL:FRESH AIR. GET
MEDICA L ATTENTION IMMEDIATELY. INGEST:DILUTE W/PLENTY OF WATER. DO
NOT INDUCE VOMITING. MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:>392F,>200C
Extinguishing Media:WATER, FOAM, CO*2.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:COMBUSTIBLE. TOXIC FUMES MAY BE EVOLVED
UPON EXPOSURE TO HEAT OR OPEN FLAMES (CARBON MONOXIDE,
NITROGENOXIDE, ISOCYANATE).
================== Accidental Release Measures ==================
Spill Release Procedures:PREVENT CONTACT W/EYES, SKIN & CLOTHING.
PREVENT RINSES FROM ENTERING DRAINS OR OTHER WATERWAYS. SOAK UP IN
ABSORBENT MATERIAL & COLLECT IN SUITABLE CONTAINER. DO NOT SEAL
(CO*2). RESIDUAL RESIN MAY B E REMOVED USING STEAM OR HOT WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS AT LOW
TEMPERATURES.
Other Precautions:IN CASE OF ACCIDENT OR IF YOU FEEL UNWELL, SEEK
MEDICAL ADVICE IMMEDIATELY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED MASK TYPE A2-P2.
Ventilation:RECOMMENDED ENGINEERING CONTROLS & MONITORING CONTROLS:
AUER, DRAGER.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . PROTECTIVE CLOTHING (APRON).
Work Hygienic Practices:PRACTICE GOOD CAUTION & PERSONAL CLEANLINESS TO
AVOID SKIN/EYE CONTACT.
Supplemental Safety and Health
VP:<0.00001 MBAR. MATLS TO AVOID:MELTING POINT. (POLYUREA) THIS
REACTION IS ACCELERATED BY SURFACTANTS (DETERGENTS OR BY WATER
SOLUBLE SOLVENTS. POLYUREA IS INERT & NON DEGRADABLE. SLIGHTLY
HAZARDOUS TO WATER).
================== Physical/Chemical Properties ==================
Vapor Pres:SUPP DATA
Spec Gravity:1.23
Solubility in Water:REACTS
Appearance and Odor:YELLOW LIQUID; EARTHY, MUSTY ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
EXOTHERMIC RXN W/AMINES & ALCOHOLS. REACTS W/WATER AT INTERFACE PRDCG
CO*2 & FORMING SOLID & INSOL PROD W/HIGH (SUPDAT)
Stability Condition to Avoid:TEMPERATURES ABOVE 50C & BELOW 0C.
Hazardous Decomposition Products:CARBON MONOXIDE, NITROGENOXIDE,
ISOCYANATE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . BURN IN AN ADEQUATE INCINERATOR OR BURY IN AN
APPROVED LANDFILL, I/A/W LOCAL & NATIONAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BATTERY, ELECTRIC, STORAGE, WET
CAGE:70658
CAGE:0FGN2
CAGE:70658
============= Composition/Information on Ingredients =============
Ingred Name:LEAD (SARA III)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 50%
Other REC Limits:NONE NORMALLY REQUI.
OSHA PEL:0.05 MG/M3;1910.1025
ACGIH TLV:0.15 MG/M3;DUST 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SULFURIC ACID (SARA III)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 27%
Other REC Limits:NONE SPECIFIED BY M.
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: SULFURIC ACID MAY CAUSE
IRRITATION OF EYES, NOSE AND THROAT. PROLONGED CONTACT MAY CAUSE
SEVERE BURNS. CHRONIC: REPEATED CONTACT CAUSES IRRITATION AND SKIN
BURNS. REPEATED EXPOSURE TO MIST MAY CAUSE EROSION OF TEETH,
CHRONIC-EYE IRRITATION, INFLAMMATION OF THE NOSE, THROAT AND
BRONCHIAL TUBES.
Explanation of Carcinogenicity:PER MANUFACTURER. HOWEVER, LEAD AND LEAD
COMPOUNDS ARE LISTED BY NTP AND IARC AS POSSIBLY CARCINOGENIC.
Effects of Overexposure:COUGH, INCREASED RESPIRATORY RATE, STINGING,
BURNS/IRRITATION OF EYES AND SKIN, DISCOLORATION OF TEETH.
Medical Cond Aggravated by Exposure:EXPOSURE TO ACID MIST CAN AGGRAVATE
PULMONARY DISORDERS.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR, PROVIDE CPR/OXYGEN IF NEEDED.
EYE CONTACT:FLUSH WITH WATER FOR 15 MINUTES. SKIN CONTACT:FLUSH
WITH WATER, AND WASH WITH SOAP AND WATER. GET MED ATTENTION IF
SYMPTOMS PE RSIST. INGESTION:DO NOT INDUCE VOMITING,DRINK 2-3
GLASSES OF WATER AND GET MEDICAL HELP IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS WHEN
FIGHTING FIRE.
Unusual Fire/Explosion Hazard:GENERATES FLAMMABLE HYDROGEN GAS WEHN
CHARGED. KEEP SOURCES OF IGNITION AWAY.
================== Accidental Release Measures ==================
Spill Release Procedures:APPLY EQUAL AMOUNT OF BAKING SODA, SODA ASH,
CAUSTIC SODA OR EQUIVALENT OVER SPILLED ELECTROLYTE TO NEUTRALIZE
IT AND ADD WATER IF NECESSARY TO FORM A SLURRY. SCOOP UP SLURRY.
Neutralizing Agent:BAKING SODA, SODA ASH, CAUSTIC SODA
======================Handling and Storage ======================
Handling and Storage Precautions:STORE WITH VENT SIDE UP. BE CERTAIN
VENTS ARE FREE OF DIRT, ETC TO ENSURE AIR FLOW.
Other Precautions:DO NOT SHORT OUT POSITIVE AND NEGATIVE ELECTRODES
WITH A CONDUCTOR. THIS MAY CUASE A HOT ELECTRICAL SPARK. DO NOT
OVERCHARGE BATTERIES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED
Ventilation:GENERAL SHOULD BE SUFFICIENT
Other Protective Equipment:WORK CLOTHING, EMERGENCY EYEWASH/SHOWER
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:C1
pH:<2
Appearance and Odor:12 VOLT, 25 AMPERE HOUR LEAD ACID STORAGE BATTERY,
SEALED, PLASTIC CASING.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OPEN FLAMES
Stability Condition to Avoid:PHYSICAL DAMAGE TO BATTERY CASING
Hazardous Decomposition Products:HYDROGEN GAS, OXIDES OF SULFUR AND
METAL OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT DISPOSE OF BATTERIES. SPENT OR UNUSED
BATTERIES SHOULD BE RECYCLED BY A LICENSED BATTERY RECYCLER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:102 8869 READYMATIC DENTAL DEVELOPER & REPLENISHER
Kit Part:Y
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 85-90%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM SULFITE
CAS:7757-83-7
RTECS #:WE2150000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM SULFITE
CAS:10117-38-1
RTECS #:WT3530000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIETHYLENE GLYCOL
CAS:111-46-6
RTECS #:ID5950000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:HYDROQUINONE (SARA 302/313) (CERCLA)
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: 2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9495
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT W/STRONG ACIDS/HEAT SULFITES
MAY LIBERATE SULFUR DIOXIDE GAS WHICH IRRIT RESP TRACT.SOME
ASTHMATICS/SULFITE-SENS INDIVIDUALS MAY EXPERIENCE WHEEZING/CHEST
TIGHTNESS.INHAL:EXPECTED TO BE LOW HA Z FOR RECOMMENDED
HNDLG.EYES/SKIN:IRRIT.MAY CAUSE ALLERGIC SKIN
REACTION.INGEST:EXPECTED TO BE LOW INGEST HAZ.
Explanation of Carcinogenicity:PER MSDS:CARCINOGENICITY
CLASSIFICATION:IARC/ACGIH/NTP/OSHA:NONE.
Effects of Overexposure:IRRIT RESP TRACT/EYE/SKIN. ALLERGIC SKIN
REACTION. WHEEZING & CHEST TIGHTNESS.
Medical Cond Aggravated by Exposure:SOME ASTHMATICS OR
SULFITE-SENSITIVE INDIVIDUALS MAY EXPERIENCE WHEEZING OR CHEST
TIGHTNESS.
======================= First Aid Measures =======================
First Aid:INHAL:IF SYMPTOMATIC MOVE TO FRESH AIR.GET MED ATTN IF
SYMPTONS PERSIST. EYES:IMMED FLUSH W/PLENTY OF WATER FOR @LEAST
15MINS.GET MED ATTN. SKIN:IMMED REMOVE CONTAMIN CLOTH/SHOES.WASH
W/SOAP/PLENTY OF WATER.IRRIT/ALLERGIC SKIN REACTION DEVELOPS GET
MED ATTN. INGEST:DRINK 1-2 GLASSES OF WATER.SEEK MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:NONE,NON0COMBUST
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER W/LG AMTS OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID EYE/SKIN/CLOTH CONTACT.USE
W/ADEQUATE VENTI.ROUTINE USE OF NONALKALINE(ACID)TYP HNDCLNR/REG
Other Precautions:KEEP CNTNR CLSD.KEEP AWAY FROM INCOMP MATL.STRONGLY
ALKALINE AQU SOLN.PROPERTIES:MOD BIOCHEM OXY DEMAND;MAY CAUSE OXY
DEPLETION IN AQU SYS;HI POT TO AFFECT AQU ORGANISMS;MOD POT TO
AFFECT 2ND WASTE TR EATMENT MICROBIAL METABOLISM & (SUPPLEM)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES/HR)
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:EYEBATH, WASHING FACILITIES, SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS WELL AFT HNDLG.WASH CONTAMIN CLOTH
BEF REUSE;DESTROY/WASH WELL CONTAMIN SHOES.
Supplemental Safety and Health
OTHER PRECAUT:GERM &/OR EARLY GROWTH OF SOME PLANTS;HI POT TO
PHOTOCHEM/CHEM DEGRADE;LOW POT TO PERSIST IN ENVIRO.AFT DIL W/LG
AMT OF WATER & 2ND WASTE TREAT MATL NOT EXPECTED TO CAUSE ADVERSE
ENVIRO EFFECTS. SEE PNIND:B FOR OTHER PART;PERTIR:C/O 2-1GAL BT OF
DEVLPR & REPLSHER & 2-1GAL BT OF FIXER & REPLSHER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:18MM @20C
Vapor Density:0.6
Spec Gravity:1.09
pH:10.1
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID, COLORLESS, ODORLESS
Percent Volatiles by Volume:90
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:SULFUR DIOXIDE. HAZ COMBUST PROD:NONE
(NON-COMBUSTIBLE).
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE/TREATMENT/DISPOSAL MAY BE SUBJECT TO
NATIONAL/STATE/LOCAL LAWS. FLUSH TO SEWER W/LG AMTS OF WATER. CHEM
SUBJ TO REPORTING REQMTS SEC 313 TITLE III SARA/40CFR PART
372:HYDROQUINONE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:14A,B,C,H WHITE LUBE
Preparer's Name:A. B. REED
CAGE:SILOO
CAGE:050Q3
CAGE:SILOO
============= Composition/Information on Ingredients =============
Ingred Name:DISTILLATES, ACID-TREATED HEAVY NAPHTHENIC; (MINERAL OIL)
INCLUDES INGRED #2.
CAS:64742-18-3
RTECS #:PY8032000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:LITHIUM HYDROXY STEARATE
CAS:7620-77-1
Fraction by Wt: SEE #1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE:CAUSES PAIN & SOME IRRIT.
SKIN:MAY CAUSE SOME IRRITATION. CHRONIC:DERMATITIS.
Explanation of Carcinogenicity:PER MSDS:CHEMICAL LISTED AS CARCINOGEN
OR POTENTIAL CARCINOGEN:NTP/IARC/OSHA:NO.
Effects of Overexposure:EYE PAIN & SOME IRRITATION. SOME SKIN
IRRITATION. DERMATITIS.
======================= First Aid Measures =======================
First Aid:IF SYMPTOMS PERSIST CALL PHYSICIAN. INHAL:NOT APPLICABLE.
EYE:FLUSH W/LG AMTS OF WATER. SKIN:WASH W/SOAP/WATER. INGEST:CALL
PHYSICIAN IMMED.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:350F,177C
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:FOAM, CO2, DRY CHEMICALS.
Fire Fighting Procedures:TREAT AS OIL FIRE.
Unusual Fire/Explosion Hazard:TREAT AS OIL FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:TRANSFER BULK MATL INTO ANOTHER CONTAINER.
ABSORB REMAINING RESIDUE W/PROPER ABSORBENTS SUCH AS SAND, EARTH,
VERMICULITE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL DRY AREA.
Other Precautions:KEEP CONTAINERS CLOSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED.
Ventilation:NOT REQUIRED.
Other Protective Equipment:NOT NEEDED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER. HMIS:WASH HANDS
AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:300F,149C
Melt/Freeze Pt:M.P/F.P Text:NA
Decomp Temp:Decomp Text:NP
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:0.947
pH:NP
Evaporation Rate & Reference:NA
Solubility in Water:NEGLIGIBLE.
Appearance and Odor:OFF WHITE SEMI-SOLID, MINERAL OIL ODOR.
Percent Volatiles by Volume:5
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER. HMIS:AVOID
ALL IGN SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE
(FIRE).
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDACNE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. CHEMS FOUND IN SEC 313 OF EPCRA SARA TITLE III
& SUBJ TO RELEASE INVENTORY REPORTING:NONE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AP-582
CAGE:9C182
CAGE:59987
CAGE:9C182
============= Composition/Information on Ingredients =============
Ingred Name:METHYLENE CHLORIDE(SARA III)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 50%
OSHA PEL:500 PPM/C,1000; Z2
ACGIH TLV:50 PPM, A2; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PERCHLOROETHYLENE (TETRACHLOROETHYLENE) (SARA III)
CAS:127-18-4
RTECS #:KX3850000
Fraction by Wt: 2%
OSHA PEL:100 PPM
ACGIH TLV:25PPM/100,A3 STEL;94
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:PHENOL
CAS:108-95-2
RTECS #:SJ3325000
Fraction by Wt: 17%
OSHA PEL:S, 5 PPM
ACGIH TLV:S, 5 PPM; 8990
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SODIUM CHROMATE (SARA III)
CAS:7775-11-3
RTECS #:GB2955000
Fraction by Wt: 1%
OSHA PEL:0.1 PPM CRO3;CEILING
ACGIH TLV:0.05 MG CR/M3; 9192
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
Effects of Overexposure:INHAL:HEADACHE,DIZZINESS, NAUSEA. SKIN:SEVERE
BURNS, LOSS OF SKIN COLOR.EYES:SEE SUPP DATA
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR.GIVE ARTIF.RESP.GIVE OXYGEN
AFTER BREATHING STARTS.CALL DOCTOR.EYES:FLUSH IMMEDIATELY W/WATER
FOR 15 MIN.CALL DOCTOR.SKIN:WASH W/SOAP AND WATER FOLLOWED BY
RUBBING.SEE S UPP DATA
===================== Fire Fighting Measures =====================
Extinguishing Media:CO*2, DRY CHEMICAL,.FOAM OR WATER FOG
Fire Fighting Procedures:REMOVE SEALED DRUMS FROM VICINTY OF FIRE.
SEALED DRU
Unusual Fire/Explosion Hazard:MS HEATED BY FLAM OR HIGH TEMP. CAN
RUPTURE.TOXIC CHLORINE OXIDES PRODUCED
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA.ABSORB AND DISPOSE OF IN
ACCORDANCE WITH LOCAL APPLICABLE REGULATIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:TRANSPORT AND STORE IN CLOSED
CONTAINERS AT TEMPETATURES BETWEEN 40F AND 95F. DO NOT STORE IN
DIRECT SUN,HEAT,FRESH AIR INTAKES OR UNVENTILATED AREAS.
Other Precautions:OPEN BUNGS CAUTIOUSLY TO AVOID SPURTING
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER NORMAL OPERATING CONDITIONS.
Ventilation:USE DOWN DRAFT IF APPLIED BY SPRAY
Other Protective Equipment:SOLVINT RESISTANT APRON AND BOOTS.
Supplemental Safety and Health
SEVER CHEMICAL BURNS.INGESTION:POISON. ALCOHOL. INGESTION:CALL
DOCTOR.INDUCE VIMITING WITH SALT WATER,THEN GIVE BAKING SODA
SOLUTION.LIE DOWN,COVER EYE
================== Physical/Chemical Properties ==================
HCC:T4
Boiling Pt:B.P. Text:110F,43.3C
Vapor Pres:137
Vapor Density:1.52
Spec Gravity:1.2000
Evaporation Rate & Reference:212F,100C TCC
Appearance and Odor:THICK YELLOW BROWN TO BROWN EMULSION-PHENOLIC ODOR
Percent Volatiles by Volume:77.5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND STRONG OXIDIZERS.
Hazardous Decomposition Products:TOXIC OXIDES OF CHLORINE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL APPLICABLE
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NON-FLAMMABLE GAS MIXTURE
CAGE:AIRLI
CAGE:04AA7
CAGE:AIRLI
============= Composition/Information on Ingredients =============
Ingred Name:OXYGEN % WT: 0.0015-23.5
CAS:7782-44-7
RTECS #:RS2060000
Fraction by Wt: <23.5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 0-1.1%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT
Ingred Name:N-PENTANE
CAS:109-66-0
RTECS #:RZ9450000
Fraction by Wt: 0-0.75%
OSHA PEL:1000 PPM
ACGIH TLV:600 PPM; 750 STEL
Ingred Name:N-HEXANE (CERCLA).LD50: (ORAL, RAT) 28,710 MG/KG.
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: 0-0.48%
OSHA PEL:500 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CARBON MONOXIDE % WT: 0.0005-1.0
CAS:630-08-0
RTECS #:FG3500000
Fraction by Wt: <1%
OSHA PEL:50 PPM
ACGIH TLV:25 PPM
Ingred Name:NITROGEN. BP: -320.4F,-195.8C. SPEC GRAV: 0.906 (AIR=1).
VP: N/A. MP: -35.8F,-210C @ 10 PSIG. PH: N/A. (ING 7)
CAS:7727-37-9
RTECS #:QW9700000
Fraction by Wt: BALANCE
OSHA PEL:N/K
ACGIH TLV:ASPHYXIANT
Ingred Name:ING 6: EVAP RATE: N/A. SOL IN H*2O: 0.023 VOL/VOL @ 32F & 1
ATM.
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:WHEEZ, DIZZ, INDIGESTION, NAUS, UNCON & DEATH. SKIN
MAY HAVE BLUE COLOR. CHRONIC: CO APPEARS ON NAVY LIST (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: OF OCCUP CHEM REPRO HAZS. CONSULT APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZ LIST & SAFE HNDLG & (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: EXPOS INFO . ABNORM COLOR PERCEPTION & PIGMENT CHGS
IN EYES REPORTED IF EXPOS TO 420-1300 PPM OF (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:N-HEXANE FOR 5 YRS. LONG-TERM EXPOS TO LOW LEVELS OF
N-HEXANE/N-PENTANE CAN AFFECT ARM & LEG NERVES. EFTS(ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:INCL:NUMB/TINGLING SENSATION, TIREDNESS, CRAMPS, LEG
SPASMS, DFCLTY HOLDING OBJECTS/WALKING, APPETITE & (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: WT LOSS. PENTANE ISOMERS SUCH AS N-PENTANE &
PROPANE CAN CAUSE SENSIT OF HEART TO EPINEPHRINE. TARGET (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: ORGANS: RESP SYS, BLOOD SYS, CNS EFTS, CVS, REPRO
SYS. FOR MORE INFO ON HEALTH HAZARDS CONTACT NECH .
RTECS #:9999999ZZ
Ingred Name:FIRST AID: ADVERSE EFTS EXPERIENCED AFTER OVEREXP, TAKE
VICTIM/RESCUER FOR MED ATTN W/COPY OF LABEL & MSDS. REC (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: TO MD:TREAT SYMPS & ELIM OVEREXP. HYPERBARIC O*2
MOST EFFICIENT ANTIDOTE TO CO POIS; OPTIMUM RANGE 2-2.5(ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: ATM. SPEC MASK/PREFERABLY COMPRESSION CHAMBER TO
UTILIZE O*2 AT THESE PRESS REQD. AVOID ADMIN STIMULANT DRUGS.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:DISCHARGE GAS TO ATM IN WELL-VENTD
AREA/OUTDOORS; ALLOW TO DISSIPATE. MONITOR AREA & SURROUNDING
AREA(ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:FOR O*2 & CO. IF LEAKING INCIDENTALLY FROM CYL,
CNTCT SUPPLIER. FOR MORE INFO ON SPILL PROC, CNTCT NEHC .
RTECS #:9999999ZZ
Ingred Name:WASTE DISP: NONFLAM-UN 1956. SM PERCENTAGE PACKAGED IN DOT
39 CYLS ARE FLAM/OXIDIZING GAS MIXS. FOR DISP OF USED(ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20:DOT-39 CYLS IT IS ACCEPTABLE TO PLACE IN LANDFILL IF
LOC LAWS PERMIT. FOR MORE WASTE DISP INFO CNTCT NEHC .
RTECS #:9999999ZZ
Ingred Name:HNDLG/STOR:AREAS AWAY FROM HEAT, IGNIT & DIRECT SUN.
PROTECT FROM PHYSICAL DMG. SEGREGATE FULL & EMPTY CYLS. USE(ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22:FIRST-IN, FIRST-OUT INVENTORY SYS. CYLS ARE NOT
REFILLABLE; TO DO SO MAY CAUSE PERSONAL INJURY/PROPERTY (ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23: DAMAGE. FOR MORE INFO ON HNDLG/STOR PRECS, CONTACT
NEHC .
RTECS #:9999999ZZ
Ingred Name:HYGIENE PRACT: REPAIR/ADJUST/MODIFY CYLS CONTAINING CO. IF
MANFUNC OR OPERATION PROB, CNTCT NEAREST DISTRIBUTOR IMMED.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 4
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:DUE TO SM SIZE OF INDIVIDUAL
CYL, NO UNUSUAL HLTH EFTS ANTIC UNDER ROUTINE CIRCUMSTANCES.
HOWEVER, CO IS TOX TO HUMANS. SYMPS OF CO POIS CAN DEVELOP
GRADUALLY/ARISE SUDDENLY DEPENDING ON CONC & DURATION OF EXPOS.
LIPS & FINGERNAILS TURN BRIGHT RED-A SIGN OF SIGNIFICANT CO
OVEREXP. OTHER SYMPS: (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: RESP DFCLTY, HDCH, SHORTNESS OF BRTH,
WHEEZ, BLURRED VISION, MEMORY LOSS, DIZZ, INDIGESTION, NAUS, UNCON
& DEATH. INHAL OVEREXP TO OTHER COMPONENTS CAN CAUSE ANESTH EFTS &
MOTOR NEUROPATHY ( IE PAIN & TINGLING IN FEET & HANDS). POTNTL FOR
EXPOS TO O*2-DEFICIENT ATM WHEN THIS GAS MIX CNTNS <19.5% O*2.
(SUPDAT)
Medical Cond Aggravated by Exposure:PRODUCT: RESP CNDTNS. CO: SOME
DISEASES OF CVS SUCH AS CORONARY ARTERY DISEASE & ANGINA PECTORIS.
HEXANE OR N-PENTANE: CNS CNDTNS, EYE DISORDERS OR SKIN PROBS.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMED. EYES:IMMED FLUSH W/WATER FOR AT LST 15
MIN, SEEK ASSISTANCE FROM MD. SKIN:FLUSH W/COPIOUS AMTS OF WATER.
CALL MD. RESCUERS SHOULD NOT ATTEMPT TO RETRIEVE VICTIM S W/ADEQ
PPE. AT MINIMUM NIOSH APPRVD SCBA MUST BE WORN. INHAL:IF ADVERSE
SYMPS DEVELOP, REMOVE TO FRESH AIR AS QUICKLY AS POSS. ONLY TRAINED
PERS SHOULD ADMIN SUPPLEMENTAL O*2 &/OR CPR. IF (ING 15)
===================== Fire Fighting Measures =====================
Extinguishing Media:NON-FLAMMABLE GAS MIXTURE. USE EXTINGUISHING MEDIA
APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:THIS GAS MIXTURE IS NOT FLAMMABLE;
HOWEVER, CONTAINERS, WHEN INVOLVED IN FIRE, MAY RUPTURE OR BURST IN
THE HEAT OF THE FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:IN RELS IN WHICH ATM UNKNOWN & OTHER CHEMS
POTNTLY INVOLVED, EVACUATE IMMED AREA; TRAINED PERS USING
PRE-PLANNED PROCS SHOULD RESPOND. IN CASE OF LEAK, CLEAR AREA,
PROTECT PEOPLE & RESPOND W/TRAINED P ERS. FOR EMER DISP SECURE CYL
& SLOWLY (ING 18)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:FIRMLY SECURE CYLS TO PVNT FALL/BEING
KNOCKED OVER. PROTECT CYLS FROM ENVIRONMENT & KEEP AT ROOM TEMP
(21C,70F). STORE CYLS IN DRY, WELL-VENTD(ING 22_
Other Precautions:WHEN 2/MORE GASES/LIQUEFIED GASES MIXED, HAZ
PROPERTIES MAY COMBINE TO CREATE ADDNL, UNEXPECTED HAZS. EVALUATE
SFTY INFO FOR EACH INGRED BEFORE PRODUCING MIX. CONSULT TRAINED
PERS TO MAKE END PROD EVA LUATION. CNTCT NEHC FOR MORE INFO.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPEC RESP PROT REQD UNDER NORM USE. USE NIOSH
APPRVD SUPPLIED AIR RESP IF CO LEVELS EXCEED EXPOS LEVELS GIVEN/IF
OXYG LEVELS <19.5% OR IF EITHER LEVEL UNKNOWN DURING EMER RESPONSE
TO RELS. FOLLOW O SHA RESP STDS OR EQUIVALENT STATE STDS.
Ventilation:USE PROD IN WELL-VENTD AREAS. IF USED IN POORLY-VENTD AREA,
INSTALL AUTOMATIC MONITOR EQUIP TO DETECT OXYG & CO LEVELS.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER . NO
SPECIAL PROTECTION IS NEEDED UNDER NORMAL CIRCUMSTANCES OF USE.
Work Hygienic Practices:BE AWARE OF DIZZ/FATG; EXPOS TO FATAL CONCS OF
PROD COULD OCCUR W/OUT ANY SIGNIFICANT WARNING SYMPS. DO NOT (ING
25)
Supplemental Safety and Health
APPEAR/ODOR: FAINT, SOLVENT-LIKE ODOR. MATLS TO AVOID: ARE INCOMPAT
W/STRONG OXIDIZERS. CO IS MILDLY CORR TO NICKEL & IRON (ESP AT HIGH
TEMPS & PRESS). DECOMP PRODS: NOT DECOMPOSE, PER SE, BUT CAN REA CT
W/OTHER CMPDS IN HEAT OF FIRE. EFTS OF OVEREXP: SYMPS:RESP DFCLTY,
RINGING IN EARS, HDCH, SHORTNESS OF BRTH, (ING 8)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:SEE ING 6
Melt/Freeze Pt:M.P/F.P Text:SEE ING 6
Vapor Pres:SEE ING 6
Spec Gravity:SEE ING 6
pH:ING 6
Evaporation Rate & Reference:SEE ING 6
Solubility in Water:SEE ING 6
Appearance and Odor:THIS PRODUCT IS COLORLESS GAS WHICH IS EITHER
ODORLESS OR WHICH HAS A (SUPDAT)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
TITANIUM WILL BURN IN NITROGEN. LITHIUM RACTS SLOWLY W/NITROGEN AT
AMBIENT TEMPS. PROPANE, N-PENTANE, N-HEXANE (SUPDAT)
Stability Condition to Avoid:CONTACT W/INCOMPATIBLE MATERIALS.
CYLINDERS EXPOSED TO HIGH TEMPERATURES OR DIRECT FLAME CAN RUPTURE
OR BURST.
Hazardous Decomposition Products:THERMAL DECOMP PRODS OF PROPANE,
N-HEXANE & N-PENTANE INCL CARBON OXIDES. OTHER COMPONENTS OF THIS
GAS MIX DO (SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE DISP MUST BE I/A/W APPROP FED, STATE &
LOCAL REGS. DOT 39 CYLS SHIP AS HAZ WHEN FULL. ONCE RELIEVED OF
PRESS (EMPTY), NOT CONSIDERED HAZ MATL/WASTE. RESIDUAL GAS IS NOT
ISSUE BECAUSE TOX GAS MIX S PROHIBITED. CALIBRATION GAS MIXS ARE
(ING 20)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:03985 SLURRY
CAGE:DIVVE
CAGE:DIVVE
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE, CAUSTIC SODA, LYE * 96-3 *
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: <13%
Other REC Limits:2MG/M3 CEILING NIOSH
OSHA PEL:2 MG/CUM
ACGIH TLV:2 MG/CUM CEILING
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SODIUM TRIPOLYPHOSPHATE (STPP)
CAS:7758-29-4
RTECS #:YK4570000
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Ingred Name:SODIUM HYPOCHLORITE, HYPOCHLOROUS ACID SODIUM SALT
CAS:7681-52-9
RTECS #:NH3486300
Fraction by Wt: <3%
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CORROSIVE TO SKIN & EYES. MISTS ARE
CORROSIVE TO SKIN, EYES & RESPIRATORY TRACT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:CORROSIVE TO SKIN & EYES. MISTS ARE CORROSIVE
TO SKIN, EYES & RESPIRATORY TRACT.
Medical Cond Aggravated by Exposure:SENSITIVE EYES, SKIN, IMPAIRED
PULMONARY FUNCTION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH THOROUGHLY W/WATER, WASH W/SOAP & WATER.
INGESTION: GIVE MILK/WATER. DON'T INDUCE VOMITING. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:DOESN'T BURN.
Fire Fighting Procedures:KEEP COOL.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: FLUSH INTO DRAIN. LARGE: COLLECT &
RETURN TO CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED. KEEP FROM
FREEZING. UN1719
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:NONE
Other Protective Equipment:SAFETY APRON
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:215F
Vapor Pres:17.5
Spec Gravity:1.35
Evaporation Rate & Reference:(BU AC=1): >1
Solubility in Water:COMPLETE
Appearance and Odor:WHITE SLURRY W/CHLORINE ODOR
Percent Volatiles by Volume:60
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
FLAMMABLE LIQUIDS, ACTIVE METALS, ORGANIC HALOGEN COMPOUNDS, STRONG
ACIDS.
Hazardous Decomposition Products:OXIDES OF CARBON HYDROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:REMOVE/DEFACE LABEL BEFORE SELLING
CONTAINER/DISPOSAL CONCENTRATE PH ADJUSTMENT, DISCHARGE TO DRAIN.
TRIPLE RINSE EMPTY CONTAINER, RETURN TO OPERATION. CONTAINS
PHOSPHATES. DISPOSE OF IAW/FEDERAL, STA TE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:2-PHENYLBENZOTHIAZOLE 97%, 22544-4
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:2-PHENYLBENZOTHIAZOLE
CAS:883-93-2
RTECS #:DL5990000
Fraction by Wt: 97%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY BE HARMFUL BY INHALATION,
INGESTION, OR SKIN ABSORPTION. MAY CAUSE EYE AND SKIN IRRITATION.
TO THE BEST OF MANUFACTURER KNOWLEDGE, THE CHEMICAL, PHYSICAL, AND
TOXICOLOGICAL PROPERTIES HAVE NOT BEEN THOROUGHLY INVESTIGATED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT
LEAST 15 MINUTES. SKIN: IMMEDIATELY WASH WITH SOAP AND COPIOUS
AMOUNTS OF WATER. INHALATION: REMOVE TO FRESH AIR. IF NOT
BREATHING, GIVE AR TIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT,
GIVE OXYGEN. INGESTION: WASH OUT MOUTH WITH WATER PROVIDED PERSON
IS CONSCIOUS. CALL MD. WASH CONTAMINATED CLOTHING BEFORE REUSE.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL POWDER OR
APPROPRIATE FOAM.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH APPROVED RESPIRATOR, CHEMICAL
PLACE IN A BAG AND HOLD FOR WASTE DISPOSAL. AVOID RAISING DUST.
VENTILATE AREA AND WASH SPILL S ITE AFTER MATERIAL PICKUP IS
COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID INHALATION. AVOID CONTACT WITH
EYES, SKIN AND CLOTHING. AVOID PROLONGED OR REPEATED EXPOSURE. KEEP
TIGHTLY CLOSED. STORE IN A COOL DRY PLACE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:>232F,>111C
Appearance and Odor:WHITE TO YELLOW POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF: CARBON MONOXIDE,
CARBON DIOXIDE, NITROGEN OXIDES, SULFUR OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE OR MIX THE MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. OBSERVE ALL FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:JP 5
CAGE:6G112
CAGE:6G112
============= Composition/Information on Ingredients =============
Ingred Name:KEROSENE, KEROSINE (SUSPECTED ANIMAL CARCINOGEN BY IARC)
*95-2*
CAS:8008-20-6
RTECS #:OA5500000
Fraction by Wt: 100%
Other REC Limits:100 MG/CUM NIOSH
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RATS): >5 G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MODERATE IRRITATION. SKIN:
MODERATE IRRITATION & DERMATITIS. PETROLEUM DISTILLATE:
HARMFUL/FATAL IF SWALLOWED. INHALATION: RESPIRATORY IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DIZZINESS, NAUSEA, LOSS OF
CONSCIOUSNESS, DEFATTING.
Medical Cond Aggravated by Exposure:EYES, SKIN & RESPIRATORY
IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH THOROUGHLY W/WATER FOR 15 MINS. SKIN: WASH AREAS
W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING,
GIVE CPR/PREFERABLY MOUTH TO MOUTH. OBTAIN MEDICAL ATTENTION IN ALL
CASE S. NOTE TO PHYSICIAN: MATERIAL IF ASPIRATED INTO THE LUNGS MAY
CAUSE CHEMICAL PNEUMONITIS. TREAT APPROPRIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>120F
Lower Limits:0.7
Upper Limits:5
Extinguishing Media:CO2, FOAM, DRY CHEMICAL & WATER FOG.
Fire Fighting Procedures:USE WATER TO KEEP EXPOSED CONTAINERS COOL. IF
A LEAK/SPILL HASN'T IGNITED, USE WATER SPRAY TO DISPERSE THE VAPORS
& TO PROTECT MEN ATTEMPTING TO STOP LEAK.(SUPP
Unusual Fire/Explosion Hazard:RUNOFF MAY CREATE FIRE/EXPLOSION HAZARD
IN SEWER SYSTEM.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB ON FIRE RETARDANT TREATED
SAWDUST/DIATOMACEOUS EARTH. SHOVEL UP & DISPOSE OF AT AN
APPROPRIATE WASTE DISPOSAL FACILITY. RUNOFF MAY CREATE
FIRE/EXPLOSION HAZARD IN SEWER SYSTEMS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL DRY AREA. MATERIAL
MUST BE LABELED AS COMBUSTIBLE. KEEP AWAY FROM HEAT & FLAME. KEEP
CONTAINER CLOSED. USE ONLY W/ADEQUATE VENTILATION
Other Precautions:AVOID PROLONGED BREATHING OF VAPORS. AVOID CONTACT
W/EYES & SKIN. EMPTY CONTAINERS MAY CONTAIN PRODUCT RESIDUE,
FLAMMABLE/EXPLOSIVE VAPORS. DON'T CUT, PUNCTURE/WELD ON/NEAR
CONTAINER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL REQUIREMENTS UNDER ORDINARY
CONDITIONS OF USE & W/ADEQUATE VENTILATION.
Ventilation:VENTILATION DESIRABLE & EQUIPMENT SHOULD BE EXPLOSION
PROOF.
Other Protective Equipment:SAFETY GLASSES W/SIDE SHIELDS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. GOOD PERSONAL HYGIENE PRACTICES SHOULD ALWAYS BE FOLLOWED.
Supplemental Safety and Health
FIRE PROC CONT'D: WATER SPRAY MAY BE USED TO FLUSH SPILLS AWAY FROM
EXPOSURES. ENCLOSED AREAS: USE SCBA. PREVENT RUNOFF FROM FIRE
CONTROL/DILUTION FROM ENTERING STREAMS/DRINKING WATER SUPPLY. ALL
LABE L WARNINGS & PRECAUTIONS MUST BE OBSERVED UNTIL THE CONTAINER
HAS BEEN THOROUGHLY CLEANED/DESTROYED.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>400F
Melt/Freeze Pt:M.P/F.P Text:-40F
Vapor Pres:<1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR WHITE LIQUID W/MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:HEAT, FLAME, STRONG OXIDATION.
Hazardous Decomposition Products:CO
==================== Disposal Considerations ====================
Waste Disposal Methods:PRODUCT IS SUITABLE FOR BURNING IN AN ENCLOSED,
CONTROLLED BURNER FOR FUEL VALUE/DISPOSAL BY SUPERVISED
INCINERATION/SUITABLE FOR PROCESSING BY AN APPROVED RECYCLING
FACILITY IAW/FEDERAL, STATE & LOCA L REGULATIONS. COMBUSTIBLE
LIQUID UN1223.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SODIUM DODECYL SULFATE SOLN, F MOL BIOL, 10% IN WATER, 71736
CAGE:63181
CAGE:63181
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM DODECYL SULFATE; (SULFURIC ACID, MONODODECYL ESTER,
SODIUM SALD)
CAS:151-21-3
RTECS #:WT1050000
= Wt:10.
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
= Wt:90.
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE TOXICOLOGICAL INFORMATION.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: HARMFUL IF INHALED OR
SWALLOWED. MAY BE HARMFUL IF ABSORBED THROUGH THE SKIN. CAUSES
SEVERE EYE IRRITATION. CAUSES SKIN IRRITATION. VAPOR OR MIST IS
IRRITATING TO THE EYES, MUCOUS MEMBRANES AND UPPER RESPIRATORY
TRACT. MAY CAUSE ALLERGIC RESPIRATORY REACTION. TO THE BEST OF
MANUFACTURER'S KNOWLEDGE, THE CHEMICAL, PHYSICAL, AND TOXICOLOGICAL
PROPERTIES HAVE NOT BEEN THOROUGHLY INVESTIGATED.
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: IMMEDIATELY FLUSH EYES OR SKIN WITH COPIOUS
AMOUNTS OF WATER FOR AT LEAST 15 MINUTES WHILE REMOVING
CONTAMINATED CLOTHING AND SHOES. ASSURE ADEQUATE FLUSHING OF THE
EYES BY SEPARATING THE E YELIDS WITH FINGERS. INHALATION: REMOVE TO
FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. INGESTION: WASH OUT MOUTH WITH
WATER PROVIDED PERSON IS CON SCIOUS. CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:NON-COMBUSTIBLE. USE EXTINGUISHING MEDIA
APPROPRIATE TO SURROUNDING FIRE CONDITIONS.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ABSORB ON SAND OR
VERMICULITE AND PLACE IN CLOSED CONTAINERS FOR DISPOSAL. VENTILATE
AREA AND WASH SPILL SITE AFTER MATERIAL PICK UP IS COMPLETE.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT BREATHE VAPOR. DO NOT GET IN
EYES, ON SKIN, ON CLOTHING. AVOID PROLONGED OR REPEATED EXPOSURE.
SEVERE EYE IRRITANT. STRONG SENSITIZER. TOXIC. KEEP TIGHTLY CLOSED.
STORE IN A COOL DRY PLACE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER . WEAR PROTECTIVE CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
OTHER INFORMATION: ONLY SELECTED REGISTRY OF TOXIC EFFECTS OF CHEMICAL
SUBSTANCES (RTECS) DATA IS PRESENTED HERE. SEE ACTUAL ENTRY IN
RTECS FOR COMPLETE INFORMATION.
================== Physical/Chemical Properties ==================
Spec Gravity:1.010
Appearance and Odor:LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:TOXIC FUMES OF CARBON MONOXIDE, CARBON
DIOXIDE, SULFUR OXIDES.
=================== Toxicological Information===================
Toxicological Information:RTECS #: WT1050000 SULFURIC ACID, MONODODECYL
ESTER, SODIUM SALT. IRRIT DATA: SKN-HMN 250 MG/24H MLD; TXAPA9 31,
481, 1975. SKN-HMN 25 MG/24H MLD; JSCCA5 23, 371, 1972. SKN-MUS 25
MG/24H MOD; JSCCA5 2 3, 371, 1972. SKN-DOG 25 MG/24H MLD; JSCCA5
23, 371, 1972. SKN-RBT 50 MG/24H SEV; BIOFX 23-3/1971. SKN-RBT 25
MG/24H MOD; JSCCA5 23, 371, 1972. SKN-RBT 250 MG/24H MOD; TXAPA9
31-481, 1975. SKN-RBT 10 MG/24H; DCTODJ 1, 305, 1978. SKN-RBT 50
MG/24H MLD; TXAPA9 21, 369, 1972. EYE-RBT 100 MG/24H MOD; 28ZPAK -,
305, 1972. EYE-RBT 250 UG MLD; AROPAW 34, 99, 1945. EYE-RBT 2 MG;
DCTODJ 1, 305, 1978. EYE-R BT 10 MG MOD; TXAPA9 55, (OTHER INFO)
===================== Ecological Information =====================
Ecological:DATA NOT YET AVAILABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE OR MIX THE MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. OBSERVE ALL FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:CONTACT FLUKA CHEMICAL COMPANY FOR TRANSPORATION
INFORMATION.
===================== Regulatory Information =====================
Federal Regulatory Information:EUROPEAN INFO: HARMFUL. R 20/22 HARMFUL
BY INHAL & IF SWALLOWED. R 42 MAY CAUSE SENSIT BY INHAL. R 36/37/38
IRRITATING TO EYES, RESP SYS & SKIN. R 41 RISK OF SERIOUS DMG TO
EYES. S 26 IN CASE OF CONTW/EYES, RINSE IMMED W/PLENTY OF WATER
&SEEK MED ADVICE. S 36 WEAR SUITABLE PROT CLTHG. S 23 DO NOT
BREATHE VAP. REVIEWS, STDS, & REGS: OEL=MAK. EPA FIFRA 1988
PESTICIDE SUBJECT TO REGISTRATION/RE-REGI STRATION FEREAC 54, 7740,
1989. NOHS 1974: HZD 81990; NIS 167; TNF 32028; NOS 113; TNE
388848. NOES 1983: HZD 81990; NIS 232; TNF 46312; NOS 170; TNE
886968; TFE 415360. (STATE REGS)
State Regulatory Information:N/P --FEDERAL REGULATIONS: EPA TSCA
SECTION 8 (B) CHEMICAL INVENTORY. EPA TSCA SECTION 8 (D)
UNPUBLISHED HEALTH/SAFETY STUDIES. EPA TSCA SECTION 8 (E) RISK
NOTIFICATION, 8EHQ-0892-8800. EPA TSCA TEST SUBMISSION (TSCATS)
DATA BASE, DECEMBER 1998.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:A-A-15 POLISH, AUTO, T II, PASTE
Preparer's Name:A. VADASZ
CAGE:0J4J4
CAGE:0J4J4
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: <20%
Other REC Limits:NONE SPECIFIED
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:UNKNOWN IARC:UNKNOWN OSHA:NO
Health Hazards Acute and Chronic:CAUSES EYE IRRITATION, DRYING OF SKIN,
DIZZINESS. CHRONIC:RESPIRATORY TRACT IRRITATION, DERMATITIS. TARGET
ORGANS: SKIN, EYES, RESPIRATORY SYSTEM.
Effects of Overexposure:EXCESSIVE INHALATION MAY CAUSE HEADACHE &
DIZZINESS
Medical Cond Aggravated by Exposure:DERMATITIS. BRONCHO-PULMONARY
PROBLEMS
======================= First Aid Measures =======================
First Aid:EYE & SKIN CONTACT:BLOT WITH TOWEL, FLUSH WITH LARGE
QUANTITIES OF WATER. INHALATION:REMOVE TO FRESH AIR. INGESTION:
INDUCE VOMITING, GET IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:141 F/61 C
Autoignition Temp:Autoignition Temp Text:500F
Lower Limits:1.0
Upper Limits:6.0
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM, DRY CHEMICAL.
(PH: 8.2 +/- .5)
Fire Fighting Procedures:COOL CONTAINERS WITH WATER. USE SELF CONTAINED
BREATHING APPARATUS. BURNING PRODUCT IS TOXIC.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY BURST WHEN EXPOSED
TO EXTREME HEAT. ISOLATE FROM HEAT, SPARKS & OPEN FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE & COLLECT MATERIAL INTO METAL CONTAINER.
USE NON-SPARKING TOOLS. USE WATER OR FOAM SPRAY TO LESSEN FIRE
HAZARD. USE ABSORBENT FOR SMALL SPILL.
======================Handling and Storage ======================
Handling and Storage Precautions:COMBUSTIBLE, KEEP AWAY FROM HEAT,
SPARKS & OPEN FLAME. USE ADEQUATE VENTILATION. AVOID PROLONGED OR
REPEATED CONTACT.
Other Precautions:STORE IN SECURE AREA. DISPOSE OF EMPTY CONTAINERS
SAFELY. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE SELF CONTAINED BREATHING APPARATUS FOR
CONCENTRATIONS ABOVE THRESHOLD LIMIT VALUE
Ventilation:LOCAL RECOMMEND.MECH:REQUIRED,EXCHANGE EVERY 10-15 MIN.
SPECIAL:BLOW AIR TO PITS/DEPRESSIONS.ASSURE FRESH AIR CIRCULATIO
Other Protective Equipment:APRON OR SHOP COAT RECOMMENDED
Work Hygienic Practices:DO NOT EAT/DRINK OR SMOKE NEXT TO MATERIAL.
WASH HANDS/FACE AFTER WORK.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F8
Boiling Pt:B.P. Text:230F,110C
Vapor Pres:2.0
Vapor Density:4.7
Spec Gravity:0.82
pH:*
Evaporation Rate & Reference:0.06 (BU AC=1)
Solubility in Water:APPRECIABLE
Appearance and Odor:GREEN, SOFT PASTE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME & FIRE
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
MONOXIDE & DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:RECYCLE, INCINERATE OR USE HAZARDOUS WASTE
MANAGEMENT FACILITY FOR DISPOSAL ACCORDING TO STATE & FEDERAL
REGULATIONS. EPA WASTE NO. D001.
| 1 | gloves_mandatory |
=======================================================
NIIN: 01-332-3736
Product ID: ECO SURE, BLUE, 35109 (0674-350), 0672D859
Cage: 0FTT5
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 0FTT5
=======================================================
Contractor Summary
=======================================================
Cage: 0FTT5
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: ENAMEL
Specification Number: A-A-2787
Type/Grade/Class: TYPE I
Unit of Issue: PT
UI Container Qty: 0
=======================================================
Ingredients
=======================================================
Cas: 108-88-3
RTECS #: XS5250000
% Wt: 14.14
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 200 PPM
ACGIH TLV: 100 PPM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 74-98-6
RTECS #: TX2275000
% Wt: 13.15
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 1000 PPM
ACGIH TLV: 1000 PPM
------------------------------
Cas: 115-10-6
RTECS #: PM4780000
% Wt: 7.30
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Cas: 110-12-3
RTECS #: MP3850000
% Wt: 6.54
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 50 PPM
ACGIH TLV: 50 PPM
------------------------------
Cas: 64742-95-6
RTECS #: ZE2190000
% Wt: 6.54
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 50 PPM
------------------------------
Cas: 64742-95-6
RTECS #: ZE2190000
% Wt: <3.27
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 5 PPM
------------------------------
Cas: 1330-20-7
RTECS #: ZE2100000
% Wt: <3.27
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 100 PPM
ACGIH TLV: 100 PPM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 107-87-9
RTECS #: SA7875000
% Wt: <3.27
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 200 PPM
ACGIH TLV: 200 PPM
------------------------------
Cas: 108-10-1
RTECS #: SA9275000
% Wt: <3.27
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 100 PPM
ACGIH TLV: 50 PPM
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 95-63-6
RTECS #: DC3325000
% Wt: <3.27
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 25 PPM
------------------------------
Cas: 71-36-3
% Wt: <3.27
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 50 PPM
ACGIH TLV: 100 PPM
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND
INHALING THE CONTENTS MAY BE HARMFUL OR FATAL. IN CONFINED AREAS VAPORS IN
HIGH CONCENTRATION ARE ANESTHETIC. IRRITATION TO SKIN, EYES, THROAT AND
RESPIRATORY TRACT. HARMFUL IF SWALLOWED. SEVERE EYE IRRITATION. MAY CAUSE
HEADACHES, NAUSEA AND VOMITING.
Signs And Symptions Of Overexposure: REPORTS HAVE ASSOCIATED REPEATED AND
PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN AND
NERVOUS SYSTEM DAMAGE. OVEREXPOSURE MAY RESULT IN LIGHT HEADEDNESS,
STAGGERING GAIT, GIDDI NESS AND POSSIBLE NAUSEA.
Medical Cond Aggravated By Exposure: RESPIRATORY AILMENTS.
First Aid: SKIN OR CLOTHES: WASH WITH SOAP AND WATER. WASH CLOTHES BEFORE
REUSE. EYES: FLUSH WITH WATER FOR 15 MINUTES. CONTACT PHYSICIAN IMMEDIATELY.
INGESTION: DO NOT INDUCE VOMITING. GET IMMEDIATE MEDICAL AID . NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. INHALATION: REMOVE TO FRESH AIR
AND GIVE ARTIFICIAL RESPIRATION IF NECESSARY. GET MEDICAL AID.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION AND VENTILATE AREA.
MOP SPILLS WITH INERT ABSORBENT. AVOID BREATHING VAPORS.
Waste Disposal Methods: DISPOSE OF IN ACCORD W/APPLICABLE FEDERAL, STATE &
LOCAL REGS. DON'T PUNCTURE, INCINERATE (BURN) OR STORE ABOVE 120F. EXPOSURE
TO HEAT OR PROLONGED EXPOSURE TO SUN MAY CAUSE CAN TOBURST. DISCARD EMPTY
CAN IN TRASH PICK-UP. DO NOT PLACE IN COMPACTOR.
Handling And Storage Precautions: KEEP OUT OF REACH OF CHILDREN. CONTENTS UNDER
PRESSURE. DON'T STORE WHERE TEMPS >120F/48.9C. AVOID BREATH SPRAY, MIST,
VAPOR. AVOID SKIN & EYE CONTACT
Other Precautions: AVOID CONTACT WITH EYES AND SKIN. USE WITH GOOD VENTILATION.
READ ENTIRE LABEL BEFORE USING. FOLLOW ALL LABEL DIRECTIONS. INTENTIONAL
MISUSE BY DELIBERATELY CONCENTRATING AND INHALING OR SWALLOWING CO NTENTS MAY
BE HARMFUL.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Autoignition Temp Text: 662F
Lower Limits: 2.2%
Upper Limits: 18.0%
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, SAND, WATER SPRAY.
AVOID SPREADING ANY BURNING LIQUID WITH WATER SPRAY.
Fire Fighting Procedures: WATER MAY BE INEFFECTIVE. USE TO KEEP FIRE EXPOSED
CNTNRS COOL. WEAR SCBA. USE SHIELDING TO PROTECT PERSONNEL AGAINST BURSTING,
RUPTURING, VENTING OF CONTAINERS
Unusual Fire/Explosion Hazard: DO NOT SPRAY NEAR OPEN FLAME. AT ELEVATED TEMPS
(ABOVE 120F) CONTAINERS MAY VENT, RUPTURE, BURST. AEROSOL CONTAINER. DO NOT
EXPOSE TO TEMPERATURE ABOVE 120F.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE BELOW TLV. USE NIOSH/MSHA APPROVED MASK ABOVE TLV.
Ventilation: LOCAL EXHAUST: PREFERRED. MECHANICAL (GENERAL): ACCEPTABLE AT
POINT OF MIST OR SPRAY RELEASE.
Other Protective Equipment: IMPERVIOUS CLOTHES TO PROTECT SKIN. EYE WASH
STATION.
Work Hygienic Practices: USE GOOD PERSONAL HYGIENE. DO NOT EAT, DRINK OR SMOKE
WHILE USING PRODUCT.
=======================================================
Physical/Chemical Properties
=======================================================
Vapor Pres: 70 @ 68F
Vapor Density: >1.522
Volatile Org Content %: 60
Spec Gravity: 1.185
Solubility in Water: INSOLUBLE
Appearance and Odor: BLUE/PAINT
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: EXTREME HEAT
Hazardous Decomposition Products: CARBON MONOXIDE
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: VOC: 60%; 580 G/L
=======================================================
Transportation Information
=======================================================
Trans ID NO: 126183
Product ID: ECO SURE, BLUE, 35109 (0674-350), 0672D859
Review Date: 06/15/1995
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: PT
Container QTY: 0
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: DTJ
Symbols: D
DOT Proper Shipping Name: CONSUMER COMMODITY
Hazard Class: ORM-D
Label: NONE
Non Bulk Pack: 156,306
Bulk Pack: NONE
Max Qty Pass: 30KGGROSS
Max Qty Cargo: 30KGGROSS
Vessel Stow Req: A
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: AKH
IMO Proper Shipping Name: AEROSOLS/AEROSOL PRODUCT ?
IMDG Page Number: SEE 9022
UN Number: 1950
UN Hazard Class: 9?
IMO Packaging Group: -
Subsidiary Risk Label: -
EMS Number: 2-13
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ALS
IATA UN ID Num: 1950
IATA Proper Shipping Name: AEROSOLS, FLAMMABLE
IATA PSN Modifier: (EACH NOT EXCEEDING 1 L CAPACITY)
IATA UN Class: 2.1
IATA Label: FLAMMABLE GAS
Packing Note Passenger: 203
Max Quant Pass: 75KG
Max Quant Cargo: 150KG
Packaging Note Cargo: 203
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ALR
AFI Symbols: *
AFI Proper Shipping Name: AEROSOLS, FLAMMABLE, N.O.S.
AFI PSN Modifier: (EACH NOT EXCEEDING 1L CAPACITY)
AFI Hazard Class: 2.1
AFI UN ID NUM: UN1950
Special Provisions: P4
Back Pack Reference: A6.3
=======================================================
HAZCOM Label
=======================================================
Product ID: ECO SURE, BLUE, 35109 (0674-350), 0672D859
Cage: 0FTT5
Company Name: LHB INDUSTRIES
Street: 8833 FLEISCHER PLACE
Zipcode: 63134
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND
INHALING THE CONTENTS MAY BE HARMFUL OR FATAL. IN CONFINED AREAS VAPORS IN
HIGH CONCENTRATION ARE ANESTHETIC. IRRITATION TO SKIN, EYES, THROAT AND
RESPIRATORY TRACT. HARMFUL IF SWALLOWED. SEVERE EYE IRRITATION. MAY CAUSE
HEADACHES, NAUSEA AND VOMITING.REPORTS HAVE ASSOCIATED
REPEATED AND PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLV ENTS WITH PERMANENT
BRAIN AND NERVOUS SYSTEM DAMAGE. OVEREXPOSURE MAY RESULT INLIGHT HEADEDNESS,
STAGGERING GAIT, GIDDINESS AND POSSIBLE NAUSEA.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-L-23699C TURBINE LUBRICANT
CAGE:63182
CAGE:63182
============= Composition/Information on Ingredients =============
Ingred Name:POLYOL ESTERS
Other REC Limits:NONE SPECIFIED
Ingred Name:THE MANUFACTURER STATES THAT NO HAZARDOUS INGREDIENTS ARE
PRESENT IN THIS PRODUCT.
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:LOW ORAL AND DERMAL TOXICITY. MISTS OR
FUMES FROM EXCESSIVE HEATING MAY CAUSE, RESPIRATORY, EYE AND SKIN
IRRITATION.
Effects of Overexposure:MISTS OR FUMES FROM EXCESSIVE HEATING MAY CAUSE
NAUSEA OR VOMITING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:CONTACT:WASH SKIN WITH SOAP AND WATER. FLUSH EYES WITH WATER
FOR 15 MIN. CALL A PHYSICIAN IF IRRITATION DEVELOPES.
INHALATION:REMOVE VICTIM TO FRESH AIR AND GIVE ARTIFICIAL
RESPIRATION OR OXYGEN IF NE EDED. INGESTION:DO NOT INDUCE
VOMITING.CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:490F,254C
Extinguishing Media:WATER FOG, DRY CHEMICAL, FOAM OR CARBON DIOXIDE.
Fire Fighting Procedures:BURNING WILL CAUSE TOXIC FUMES. WEAR
SELF-CONTAINED BREATHING APPARATUS AND FULL TURN-OUT GEAR TO FIGHT
FIRE. AVOID SPREADING LIQUID AND FIRE BY WATER FLOODING.
Unusual Fire/Explosion Hazard:EXPOSURE TO HEAT BUILDS UP PRESSURE IN
CLOSED CONTAINERS. COOL WITH WATER SPRAY.
================== Accidental Release Measures ==================
Spill Release Procedures:COVER WITH AN ENERT ABSORBENT MATERIAL AND
REMOVE TO DISPOSAL CONTAINER. OBEY ALL RELEVENT FEDERAL, STATE AND
LOCAL LAWS.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT USE ABOVE 490F. WIPE UP SPILLS
IMMEDIATELY. AVOID EYE AND SKIN CONTACT.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF OVERHEATED, USE APPROPRIATE NIOSH-APPROVED
RESPIRATORY PROTECTIVE EQUIPMENT.
Ventilation:LOCAL EXHAUST AND MECHANICAL VENTILATION RECOMMENDED.
Other Protective Equipment:EYE WASH FOUNTAIN. SAFETY SHOWER.
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:>450F,>232C
Vapor Pres:<1.0
Vapor Density:>1
Spec Gravity:<1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:ORANGE CLEAR LIQUID, MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS.
Hazardous Decomposition Products:BURNING WILL PRODUCE TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:OBEY RELEVENT LOCAL, STATE AND FEDERAL LAWS. DO
NOT CONTAMINATE ANT LAKES, STREAMS, PONDS OR UNDERGROUND WATER
SUPPLY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SUPERIOR 601
CAGE:87618
CAGE:56406
CAGE:87618
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM HYDROGEN FLUORIDE
CAS:7789-29-9
RTECS #:TS6650000
Fraction by Wt: 10-30%
Other REC Limits:NONE SPECIFIED
OSHA PEL:2.5 MG/M3
ACGIH TLV:2.5 MG/M3
Ingred Name:BORIC ACID
CAS:10043-35-3
RTECS #:ED4550000
Fraction by Wt: 25-55%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:POTASSIUM FLUOBORATE
CAS:14075-53-7
RTECS #:ED2800000
Fraction by Wt: 7-20%
Other REC Limits:NONE SPECIFIED
OSHA PEL:2.5 MG/M3
Ingred Name:POTASSIUM CARBONATE
CAS:584-08-7
RTECS #:TS7750000
Fraction by Wt: 3-12%
Other REC Limits:NONE SPECIFIED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 10-25%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN/RESPIRATORY TRACT:
IRRITATION.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:FUMES ARE IRRITATING TO THE SKIN, EYES AND THE
RESPIRATORY TRACT.CAN CAUSE FAINTNESS AND NAUSEA.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN,
RESPIRATORY TRACT OR NERVOUS SYSTEM MAY BE AT INCREASED RISK FROM
EXPOSURE. DRYING/CRACKING OF SKIN.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH RUNNING WATER FOR 15 MINUTES WHILE HOLDING
EYELID. GET MEDICAL ATTENTION IMMEDIATELY. SKIN: WASH WITH SOAP &
WATER. REMOVE CONTAMINATED CLOTHING. GET MEDICAL ADVICE.
INHALATION: REMOV E TO FRESH AIR. GIVE MOUTH-TO-MOUTH RESUSCITATION
IF NOT BREATHING. GET MEDICAL ATTENTION. INGESTION: DO NOT INDUCE
VOMITING. GIVE MILK OR WATER BUT NOTHING BY MOUTH IF UNCONSCIOUS.
GET MEDICAL ATTEN.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE ANY APPLICABLE MEDIA AS APPROPRIATE FOR
SURROUNDINGS.
Fire Fighting Procedures:MATERIAL IS NONFLAMMABLE BUT OPEN FLAME AND
SPARKS CAN IGNITE COMBUSTIBLES. FIRE-FIGHTERS SHOULD USE
APPROPRIATE PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:LARGE SPILLS SHOULD BE NEUTRALIZED WITH A
SLAKED LIME-SODA ASH SLURRY. WASH RESIDUAL SPILL AREAS WITH WATER.
Neutralizing Agent:SLAKED LIME-SODA ASH.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS, AND OPEN
FLAME. DURING USE AND UNTIL ALL VAPORS ARE GONE: KEEP AREA
VENTILATED-DO NOT SMOKE.
Other Precautions:AVOID BREATHING OF FUMES ESPECIALLY IN CONFINED
SPACES,
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED RESPIRATOR IF
VENTILATION DOES NOT MAINTAIN INHALATION EXPOSURES BELOW PEL/TLV.
WEAR SELF-CONTAINED BREATHING APPARATUS IF REQUIRED FOR HIGH LEVELS
OF CONTAMINATES.
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF THE
EXPOSURE IS MAINTAINED BELOW APPLICABLE EXPOSURE LIMITS.
Other Protective Equipment:INDUSTRIAL-TYPE WORK CLOTHING, HAT AND
LEATHER APRON. AN EYE WASH AND DRENCH SHOWER FACILITY SHOULD BE
AVAILABLE.
Work Hygienic Practices:USE WITH ADEQUATE VENTILATION. AVOID BREATHING
VAPOR/SPRAY MIST. AVOID CONTACT WITH SKIN & EYES. WASH HANDS AFTER
USE.
Supplemental Safety and Health
KEEP CONTAINER CLOSED WHEN NOT IN USE. TRANSFER ONLY TO APPROVED
CONTAINERS WITH COMPLETE AND APPROPRIATE LABELING. DO NOT TAKE
INTERNALLY.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.54
Solubility in Water:99%
Appearance and Odor:WHITE ODORLESS PASTE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALINE MATERIALS, AMMONIA
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:FLUORIDES, FLUORINE, HYDROGEN
FLUORIDE, OZONE, BORON TRIFLUORIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:GLUTOSE-ORAL GLUCOSE GEL
Preparer's Name:PATRICK L JOHNSON
CAGE:55763
CAGE:55763
============= Composition/Information on Ingredients =============
Ingred Name:D-GLUCOSE;(DEXTROSE ANHYDROUS)
CAS:50-99-7
RTECS #:LZ6600000
Fraction by Wt: 40%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:GLYCEROL; (GLYCERIN)
CAS:56-81-5
RTECS #:MA8050000
Fraction by Wt: 5%
OSHA PEL:15 MG/M3 (MIST)
ACGIH TLV:10 MG/M3 (MIST)
Ingred Name:FLAVOR; (LEMON FLAVOR)
Fraction by Wt: 2.4%
OSHA PEL:15 MG/M3 (MIST)
ACGIH TLV:10 MG/M3 (MIST)
Ingred Name:CELLULOSE GUM
Fraction by Wt: 1%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TOXICITY IS BELIEVED TO BE EXTREMELY
LOW. ALLERGIC RXNS MAY DEVELOP IN A FEW RARE CASES. EYE/SKIN: MAY
CAUSE IRRIT. INGEST: MAY CAUSE IRRIT OF GI TRACT, NAUSEA, VOMITING
&/ALLERGIC RXN. CHRONIC: HYPER GLYCEMIA MAY DEVELOP.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:HYPERGLYCEMIA, DIABETES,
GLUCOSE-GALACTOSE INTOLERANCE. DEXTROSE TOLERANCE MAY BE IMPAIRED
IN PATIENTS W/RENAL FAILURE.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. SUPPORT BRTHG(GIVE O*2/ARTF
RESP). EYE: FLUSH W/WATER FOR AT LEAST 15 MINS, LIFTING EYELIDS
OCCASIONALLY. IF IRRIT DEVELOPS/PERSISTS, SEEK MED ATTN. SKIN: WASH
W/SOAP & WATER. IF IRRIT DEVELOPS/PERSISTS, SEEK MED ATTN. INGEST:
NOT NORMALLY HAZARD IN SMALL DOSES, HOWEVER, IF LGE DOSE IS
CONSUMED OR ADVERSE/ALLERGIC RXNS OCCUR, SEEK MED ATTN IMMED.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, FOAM AS
APPROPRIATE FOR SURROUNDING FIRE CONDITIONS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:MAY PRODUCE TOXIC FUMES IF HEATED TO
DECOMPOSITION.
================== Accidental Release Measures ==================
SPILL AREA WITH SOAP & WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL PRECAUTIONS REQUIRED. AVOID
EXPOSURE TO HEAT OR FREEZING. STORE IN A COOL, DRY PLACE.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. USE NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN.
Ventilation:NORMAL ROOM VENTILATION IS USUALLY ADEQUATE.
Other Protective Equipment:APPROPRIATE LAB APPAREL.
Work Hygienic Practices:DO NOT EAT, DRINK/SMOKE NEAR THIS MATL. WASH
ANY CONTAMD CLTHG BEFORE REUSE. AVOID WEARING CONT LENSES WHEN
(SUPDAT)
Supplemental Safety and Health
APPEAR/TASTE: TASTE & SLIGHT LEMON ODOR. HYGIENE PROC: WORKING W/THIS
MATL DUE TO POSSIBILITY OF INCREASED SEVERITY OF EYE DAMAGE.
================== Physical/Chemical Properties ==================
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR, COLORLESS, VISCOUS GEL W/SMALL BUBBLES
THROUGHOUT. SWEET LEMON (SUPDAT)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HEAT.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY PRODUCE TOXIC FUMES IF HEATED TO
DECOMPOSITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PETROLEUM ETHER
CAGE:LO894
CAGE:LO894
CAGE:60777
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTA (PETROLEUM SPIRITS OR BENZIN)
CAS:8030-30-6
RTECS #:DE3030000
Fraction by Wt: 100%
OSHA PEL:100 PPM
===================== Hazards Identification =====================
Effects of Overexposure:DIZZINESS,NAUSEA FROM BREATHING
======================= First Aid Measures =======================
First Aid:INHALATION-REMOVE TO FRESH AIR.IF NOT BREATHING,GIVE
ARTIFICIAL RESPIRATION.IF BREATHING IS DIFFICULT-GIVE OXYGEN.CALL A
PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:-50 F
Extinguishing Media:WATER SPRAY,ALCOHOL FOAM,DRY CHEMICAL,CARBON
DIOXIDE
Unusual Fire/Explosion Hazard:IS VERY FLAMMABLE
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE SOURCES OF IGNITION.FLUSH WITH
WATER.ABSORB IF POSSIBLE
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM HEAT,SPARKS,FLAME.AVOID
BREATHING VAPOR.KEEP CONTAINER TIGHTLY CLOSED.AVOID PROLONGED SKIN
CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ALL PURPOSE CANISTER MASK SHOULD BE AVAILABLE
Ventilation:LOCAL RECOMMENDED,MECHANICAL SHOULD BE NON SPARKING
Other Protective Equipment:APPROVED WORKING CLOTHES
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:20-40C
Vapor Density:2.50
Spec Gravity:0.6
Appearance and Odor:LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS
Stability Condition to Avoid:HEAT,SPARKS,OPEN FLAME
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE ABSORBED MATERIAL IN CONTAINERS SUITABLE
FOR SHIPPING FLAMMABLE MATERIALS TO DISPOSAL AREA
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:B-534-1-66 RULE 66 INSULATING VARNISH
CAGE:1PP28
Contract Num:SP0430-01-M-H345
CAGE:1PP28
Contract Num:SP0430-02-M-Q098
CAGE:1PP28
============= Composition/Information on Ingredients =============
Ingred Name:2-PROPOXYETHANOL
CAS:2807-30-9
RTECS #:KM2800000
Minumum % Wt:10.
Maxumum % Wt:15.
OSHA PEL:NOT AVAILABLE
ACGIH TLV:NOT AVAILABLE
Ingred Name:XYLENES
CAS:1330-20-7
RTECS #:ZE2100000
Minumum % Wt:.1
Maxumum % Wt:1.
ACGIH TLV:TWA: 100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYLBENZENE
CAS:100-41-4
RTECS #:DA0700000
Minumum % Wt:.1
Maxumum % Wt:1.
OSHA PEL:435 CEIL: 545 MG/M3
ACGIH TLV:100 CEIL:125 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:V.M. & P. NAPHTHA (ALIPHATIC PETROLEUM DISTILLATES)
CAS:64742-89-8
Minumum % Wt:20.
Maxumum % Wt:30.
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:METHYL ISOBUTYL KETONE
CAS:108-10-1
RTECS #:SA9275000
Minumum % Wt:.1
Maxumum % Wt:1.
OSHA PEL:100CEIL:125 PPM
ACGIH TLV:410 CEIL: 510 MG/M3
ACGIH STEL:307 MG/M3;75 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:1-BUTANOL
CAS:71-36-3
RTECS #:EO1400000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:100 PPM; 300 MG/M3
ACGIH TLV:50 PPM (SKIN)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:FORMALDEHYDE
CAS:50-00-0
RTECS #:LP8925000
Minumum % Wt:.1
Maxumum % Wt:1.
OSHA PEL:0.3 PPM
ACGIH STEL:.3 PPM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:HCS CLASS: TARGET ORGAN EFFECTS.
ACUTE: HAZARDOUS IN CASE OF SKIN CONTACT(IRRITANT), OF EYE
CONTACT(IRRITANT), OF INGESTION, OF INHALTION. SLIGHTLY DANGEROUS
IN CASE OF SKIN CONTACT(PERMEATOR). CHRONI C: HAZARDOUS IN CASE OF
SKIN CONTACT(IRRITANT), OF EYE CONTACT(IRRITANT), OF INGESTION, OF
INHALTION.
Explanation of Carcinogenicity:CLASSIFIED 4(NONE) BY IARC, NONE BY NTP,
NONE BY OSHA [V.M.&P. NAPHTHA (ALIPHATIC PETROLEUM DISTILLATES)].
CLASSIFIED D(NOT CLASSIFIABLE FOR HUMAN OR ANIMAL.) BY EPA
[1-BUTANOL]. CLASSIFIED+(PROVEN) B Y OSHA [FORMALDEHYDE].
CLASSIFIED A2(SUSPECT FOR HUMAN) BY ACGIH, 2A(PROBABLE FOR HUMAN)
BY IARC, 2(REASONABLY ANTICIPATED) BY NTP[FORMALDEHYDE].
Effects of Overexposure:OTHER TOXIC EFFECTS ON HUMANS: HAZARDOUS IN
CASE OF SKIN CONTACT (IRRITANT), OF EYE CONTACT (IRRITANT), OF
INGESTION, OF INHALATION. SLIGHTLY DANGEROUS TO DANGEROUS IN CASE
OF SKIN CONTACT (PERMEATOR) .
======================= First Aid Measures =======================
First Aid:EYE-CHECK FOR & REMOVE CONTACT LENSES. IMMEDIATELY FLUSH
WITH RUNNING WATER FOR 15 MINS, KEEP EYELIDS OPEN. CAN USE COLD
WATER. DON'T USE EYE OINTMENTS. SEEK MEDICAL AID. SKIN-IMMEDIATELY
WASH WITH P LENTY OF WATER. GENTLY & THOROUGHLY WASH SKIN WITH
RUNNING WATER & NON-ABRASIVE SOAP. BE CAREFUL TO CLEAN FOLDS,
CREVICES, CREASES & GROIN. CAN USE COLD WATER. COVER SKIN WITH AN
EMOLIENT. IF IRRITATI ON PERSISTS, SEEK MEDICAL AID.
INHALTION-ALLOW VICTIM TO REST IN WELL VENTED AREA. SEEK IMMEDIATE
MEDICAL AID. INGESTION-DO NOT INDUCE VOMITING. LOOSEN TIGHT
CLOTHES. IF BREATHING PERFORM MOUTH-TO-MOU TH RESUSCITATION. SEEK
MEDICAL AID.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:=10.C, 50.F
TAGLIABUE
Autoignition Temp:=232.C, 449.6F
Autoignition Temp Text:VM&P N
Lower Limits:1.26%
Upper Limits:15.8%
Extinguishing Media:SMALL-DRY CHEMICAL, CO2, ALCOHOL FOAM OR WATER
SPRAY. LARGE: ALCOHOL FOAM, WATER SPRAY OR FOG.
Fire Fighting Procedures:FLAMMABLE LIQUID, SOLUBLE OR DISPERSED IN
WATER. LARGE FIRE-USE ALCOHOL FOAM, WATER SPRAY OR FOG. COOL
CONTAINING VESSEL WITH WATER JET IN ORDER TO PREVENT PRESSURE
BUILD-UP, AUTOIGNITION OR EXPLOSIO N. CONTAINER EXPLOSION MAY OCCUR
UNDER FIRE CONDITIONS OR WHEN HEATED. (VM&P NAPHTHA (ALIPHATIC
PETROLEUM DISTILLATES))
Unusual Fire/Explosion Hazard:EXTREMELY FLAMMABLE IN PRESENCE OF OPEN
FLAMES & SPARKS. FLAMMABLE IN PRESENCE OF HEAT, OXIDIZING
MATERIALS, OF COMBUSTIBLE MATERIALS. SLIGHTLY FLAMMABLE TO
FLAMMABLE IN PRESENCE OF REDUCING MATERIALS .
================== Accidental Release Measures ==================
Spill Release Procedures:LARGE-KEEP AWAY FROM HEAT & SOURCE OF
IGNITION. STOP LEAK IF WITHOUT RISK. ABSORB WITH DRY EARTH, SAND,
OTHER NONCOMBUSTIBLE MATERIAL. DO NOT TOUCH SPILLED MATERIAL.
PREVENT ENTRY TO SEWER, BASEMENT O R CONFINED AREAS. ELIMINATE
SOURCE OF IGNITION. BE CAREFUL THAT PRODUCT IS NOT PRESENT AT A
CONCENTRATION LEVEL ABOVE TLV. CHECK TLV ON MSDS & WITH LOCAL
AUTHORITIES. "SEE PRECAUTION FOR SMALL SPILL"
======================Handling and Storage ======================
Handling and Storage Precautions:FLAMMABLE MATERIALS SHOULD BE STORED
IN SEPARATE STORAGE CABINET OR ROOM. KEEP AWAY FROM HEAT & SOURCES
OF IGNITION. KEEP CONTAINER TIGHTLY CLOSED. KEEP IN COOL,
WELL-VENTILATED PLACE. GROUND EQUIPMEN T CONTAINING MATERIAL. A
REFRIGERATED ROOM WOULD BE PREFERABLE FOR MATERIALS WITH FLASHPOINT
<37.8C.
Other Precautions:SMALL SPILL-DILUTE WITH WATER & MOP UP, OR ABSORB
WITH AN INERT DRY MATERIAL & PLACE IN AN APPORIATE WASTE DISPOSAL
CONTAINER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:VAPOR RESPIRATOR. WHEN THE CONCENTRATION LEVEL
IS ABOVE TLV/PEL, BE SURE TO USE A MSHA/NIOSH APPROVE RESPIRATOR OR
EQUVALENT. WEAR APPROPIATE RESPIRATOR WHEN VENTILATION IS
INADEQUATE.
Ventilation:PROVIDE EXHAUST VENTILATION OR OTHER ENGINEERING CONTROLS
TO KEEP THE AIRBORNE CONCENTRATIONS OF VAPORS BELOW THRESHOLD
VALUES.
Other Protective Equipment:LAB COAT. TO PREVENT REPEATED OR PROLONGED
OR REPEATED SKIN CONTACT, WEAR IMPERVIOUS CLOTHING AND BOOTS. FULL
SUIT.
Supplemental Safety and Health
REPEATED OR PROLONGED SKIN CONTACT, WEAR IMPERVIOUS CLOTHING & BOO
TS. A SELF CONTAINED BREATHING APPARATUS SHOULD BE SUED TO AVOID
INHALATION OF THE PRODUCT.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:=115.C, 239.F
Melt/Freeze Pt:=-89.5C, -129.1F
Vapor Pres:29.62 MMHG
Vapor Density:3.69
Spec Gravity:0.8
Viscosity:2.47CP
Evaporation Rate & Reference:0.25 (BUAC)
Solubility in Water:SOLUBLE
Appearance and Odor:LIGHT AMBER LIQUID; TASTE AND ODOR INFORMATION NOT
AVAILABLE.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTIVE WITH OXIDIZING AGENTS, REDUCING AGENTS, METALS, ACIDS.
SLIGHTLY REACTIVE TO REACTIVE WITH ORGANIC MATERIALS, ALKALIS.
NON-REACTIVE WITH MOISTURE.
Stability Condition to Avoid:NO ADDITIONAL REMARKS.
Hazardous Decomposition Products:CARBON OXIDES (CO, CO2).
=================== Toxicological Information===================
Toxicological Information:MUTAGENIC EFFECTS: NOT AVAILABLE. TERATOGENIC
EFFECTS: NOT AVAILABLE. DEVELOPMENTAL TOXICITY: NOT AVAILABLE. THE
SUBSTANCE IS TOXIC TO BLOOD, KIDNEYS, LUNGS, THE NERVOUS SYSTEM,
LIVER, MUCOUS MEMBRANE S. REPEATED OR PROLONGED EXPOSURE TO THE
SUBSTANCE CAN PRODUCE TARGET ORGANS DAMAGE. TOXICITY TO ANIMALS:
WARNING: THE LC50 VALUES HEREUNDER ARE ESTIMATED ON THE BASIS OF A
4-HOUR EXPOSURE. ACUTE ORAL TOXICITY (LD50): 1774 MG/KG[MOUSE].
(2-PROPOXYETHANOL). ACUTE DERMAL TOXICITY (LD50): 1337
MG/KG{RABBIT}. (2-PROPOXYETHANOL). ACUTE TOXICITY OF VAPOR (LC50):
8000 PPM 4HR(S)[RAT]. (1-BUTANOL).
===================== Ecological Information =====================
Ecological:ECOTOXICITY: NOT AVAILABLE. BOD5 AND COD: NOT AVAILABLE.
PRODUCTS OF BIODEGRADATION: POSSIBLY HAZARDOUS SHORT TERM
DEGRADATION PRODUCTS ARE NOT LIKELY. HOWEVER, LONG TERM DEGRADATION
PRODUCTS MAY ARI SE. TOXICITY OF THE PRODUCTS OF BIODEGRADATION:
THE PRODUCTS OF DEGRADATION ARE LESS TOXIC THAN THE PRODUCT ITSELF.
SPECIAL REMARKS ON THE PRODUCT OF BIODEGRADATION: NO ADDITIONAL
REMARKS.
==================== Disposal Considerations ====================
Waste Disposal Methods:RECYCLE TO PROCESS, IF POSSIBLE. CONSULT YOUR
LOCAL OR REGIONAL AUTHORITIES.
=================== MSDS Transport Information ===================
Transport Information:DOT CLASSIFICATION: DOT CLASS 3: FLAMMABLE
LIQUID. PROPER SHIPPING NAME: PAINT (V.M. & P NAPHTHA (ALIPHATIC
PETROLEUM DISTILLATES)) (ETHYLENE GLYCOL MONOPROPYL ETHER)
(2-PROPOXYETHANOL). DOTN IDENTIFI CATION NUMBER: UN 1263. PACKING
GROUP: II. HAZARDOUS SUBSTANCES REPORTABLE QUANTITY: NOT AVAILABLE.
DOT (PICTOGRAMS): FLAMMABLE LIQUID.
===================== Regulatory Information =====================
SARA Title III Information:SARA 313 TOXIC CHEMICALS NOTOFICATION AND
RELEASE REPORTING: 2-PROPOXYETHANOL; XYLENES; ETHYLBENZENE; METHY
ISOBUTYL KETONE; MODIFIED MELAMINE FORMALDEHYDE.
Federal Regulatory Information:TSCA INVENTORY: PRODUCT(S):
2-PROPOXYETHANOL, XYLENES, ETHYLBENZENE, V.M.&P NAPHTHA (ALIPAHTIC
PETROLEUM DISTILLATES), METHYL ISOBUTYL KETONE, MODIFIED MELAMINE
FORMALDEHYDE.
State Regulatory Information:CALIFORNIA PROP. 65: THIS PRODUCT CONTAINS
THE FOLLOWING INGREDIENTS FOR WHICH THE STATE OF CALIFORNIA HAS
FOUND TO CAUSE CANCER, BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM,
WHICH WOULD REQUIRE A WARNIN G UNDER THE STATUE: PRODUCT(S):
FORMALDEHYDE.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EXTRACTION SHAMPOO
CAGE:MEGAP
CAGE:MEGAP
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2-BUTOXY-; (ETHYLENE GLYCOL MONO BUTYL ETHER)
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: <10%
Other REC Limits:50 PPM (MFR)
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
Ingred Name:ALKOXYLATED LINEAR ALCOHOL
CAS:68213-24-1
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC:MAY CAUSE IRRITATION TO
SKIN & EYES. ANIMAL STUDIES CLEARLY DEMONSTRATED DOSE-RELATED
ADVERSE EFFECTS ON CNS, HEMATOPOIETIC TISS, BLOOD, KIDNEYS & LIVER,
ASSOC W/ADMIN OF ETHYLENE GLYCOL MONOBUTYL ETHER (EGBE).
(EXTRACTED FROM DHHS (NIOSH) PUBLICATION NO. 90-118) .
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:IRRITATION TO SKIN & EYES.
Medical Cond Aggravated by Exposure:PREEXISTING EYE & SKIN CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O2/ARTF
RESP) . SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD . EYES:FLUSH
W/WATER FOR AT LEAST 15 MINUTES. IF IRRITATION PERSISTS CONTA CT
MD. INGEST:GIVE LARGE AMOUNTS OF WATER. INDUCE VOMITING. CONTACT
MD.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:NONFLAMMABLE. MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILLS:RINSE SPILL W/WATER &/OR WIPE UP
W/TOWELS OR CLOTH. DISPOSE IN STANDARD WASTE CONTAINER. LARGE
SPILLS: RINSE CONTAMINATED AREA W/WATER. MAY BE DISPOSED OF BY WAY
OF SEWAGE SYSTEM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMPERATURES. KEEP
CONTAINERS SEALED WHEN NOT IN USE.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST: ROOM VENTILATION IS ADEQUATE.
Other Protective Equipment:AN EYEWASH SHOULD BE PRESENT IN THE
WORKPLACE.
Work Hygienic Practices:USE GOOD INDUSTRIAL HYGIENE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:T6
Boiling Pt:B.P. Text:210F,99C
Spec Gravity:1 (H2O=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR GREEN LIQUID; BUTYL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & OXIDIZERS.
Stability Condition to Avoid:EXTREMES IN TEMPERATURES.
Hazardous Decomposition Products:NONE
Conditions to Avoid Polymerization:EXCESSIVE HEAT.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . CLEAN UP ACTION SHOULD ALWAYS BE CAREFULLY PLANNED &
EXECUTED. ANY QUESTIONS REGARDING DISPOSAL SHOULD BE DIRECTED TO
APPROPRIATE AGEN CIES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ETHYL ACETATE AR
CAGE:62910
CAGE:62910
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ACETATE (SARA III)
CAS:141-78-6
RTECS #:AH5425000
Fraction by Wt: >99%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:INH:IRRITNT TO NOSE/RESP TRCT;ING:CAUSES
DIARRHEA,SORE THROAT;SKIN:DEFATS,IRRIT,EYES:IRRITATION.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR.GIVE CPR/OXYGEN IF NEEDED;INGEST:IF
SWALLOWED,GIVE TWO GLASSES OF WATER & INDUCE VOMIT.NOTHING BY MOUTH
IF UNCON;SKIN/EYE EXPOSURE:RMV CONTMNTD CLOTHG.WASH SKIN W/SOAP &
H*2O .FLUSH SKIN/EYES W/LG H*2O;GET MED HELPIMMEDIATLY
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:=-4.4C, 24.F
Autoignition Temp:=427.C, 800.6F
Lower Limits:2.2
Upper Limits:11.0
Extinguishing Media:DRY CHEMICALS,FOAM,CO*2;WATER SPRAY TO KEEP EXPOSD
CANS COOL
Fire Fighting Procedures:USE H*20 TO COOL EXPD CONTRS. USE SCBA & FULL
PROT.CLTHG.
Unusual Fire/Explosion Hazard:ABOVE FLASH POINT,VAP-AIR MIXTURES ARE
EXPLOSIVE WITHIN FLAMMABLE LIMITS;AUTO IGN TEMP:427C(800F)
================== Accidental Release Measures ==================
Spill Release Procedures:RMV IGN SOURCES.VENT AREA.USE RESP PROTCTION &
PROTCTV CLOTHG.KEEP OUT OF SURF H*2O,SEWRS/CONFND AREAS;SM
SPILL:ABSORB W/PAPER TOWELS.EVVAP UNDER FUME HOOD THEN BURN
CAREFULLY;LG SPILL:DIKE AREA.CONTA IN & RECOVER SPILL IF POSS;SHOVL
RESDUEINTO DRUMS
======================Handling and Storage ======================
Handling and Storage Precautions:PROTCT AGAINST PHYSICAL DAMAGE.STORE
IN COOL,DRY WELL VNTLTD AREA AWAY FM ING/HEAT SOURCES,OXIDZG
MATL.OUTSIDE OR DETACHED SORAGE IS PREFERRED.
Other Precautions:KEEP AWAY FROM HEAT,SPARKS,FLAMES.KEEP CONTNRS
CLOSED.USE W/ADEQUATE VENT.AVOID BRTHG DUST.WASH THOROUGHLY AFTER
HNDLG.VOND/GROUND CONTNRS WHEN TRNSFRG MATERL.USE NON-SPARKG TYPE
TOOL & EQUIP.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FULL FACE RESPIRATOR
Ventilation:LOCAL EXHAUST TO MAINTN BELOW TLV.
Other Protective Equipment:FULL PROTECTIVE CLOTHING,SAFETY SHOWER,EYE
WASH STATION
Supplemental Safety and Health
MSDS FM MR DATED:22 AUG 85,CONFORMS TO OSHA HAZ COMM STD.
================== Physical/Chemical Properties ==================
HCC:F2
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:=77.2C, 171.F
Vapor Pres:76
Vapor Density:3.0
Spec Gravity:0.9
Evaporation Rate & Reference:6(BUT ACETATE=1)
Solubility in Water:MODERATE
Appearance and Odor:COLORLESS LIQUID.PLEASANT FRUITY ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS,STRONG ALKALIES/ACIDS.NITRATES.
Stability Condition to Avoid:HEAT, IGNITION SOURCES
Hazardous Decomposition Products:CO, CO*2 WHEN HEATED TO DECOMPOSITION
Conditions to Avoid Polymerization:HEAT WILL CONTRIBUTE TO
INSTBLTY.SLOWLY DECOMPOSED BY MOISTR
==================== Disposal Considerations ====================
Waste Disposal Methods:LG SPILL & LOT SIZES OF HAZ WASTE CAN BE
ATOMIZED IN A RCRA APPRVD COMBUSTION CHAMBER OR DISPOSED OF IN A
RCRA APROVED LAND FILL FACILITY.DO NOT FLUSH TO SEWER.ENSURE
COMPLIANCE W/FED,STATE, & LOCAL R EGS; REPORTABLE QTY
(RQ)(CWA/CERCLA);5000LBS
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AMERCOAT POLYAMIDE-CURED EPOXY PROMER, 83A
CAGE:0Y2E4
CAGE:55849
CAGE:0Y2E4
============= Composition/Information on Ingredients =============
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (MAGNESIUM
SILICATE)
CAS:14807-96-6
RTECS #:MW2710000
Fraction by Wt: <15%
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: <15%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:2-PENTANONE, 4-METHYL-; (METHYL ISOBUTYL KETONE) (SARA
III). VP:15 @ 68F. LD50:2 G/KG
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 8.44%
OSHA PEL:100 PPM/75 STEL
ACGIH TLV:50 PPM/75 STEL; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:EPOXY RESIN. LD50:11.4 G/KG
CAS:25068-38-6
RTECS #:KC2100000
Fraction by Wt: <10%
Ingred Name:2-HEPTANONE; (METHYL N-AMYL KETONE). VP:4 @ 68F. LD50:1.6
G/KG
CAS:110-43-0
RTECS #:MJ5075000
Fraction by Wt: 8.02%
OSHA PEL:100 PPM
ACGIH TLV:50 PPM
Ingred Name:IRON OXIDE
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: <10%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
Ingred Name:BENZENE, ETHYL-; (ETHYL BENZENE) (SARA III). VP:7.1 @ 68F.
LD50:3.5 G/KG
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 4.21%
OSHA PEL:100 PPM; 125 STEL
ACGIH TLV:100 PPM; 125 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:EPOXY RESIN. LD50:30 G/KG
CAS:25036-25-3
Fraction by Wt: <5%
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:QUATERNARY AMMONIUM COMPOUNDS, BIS(HYDROGENATED TALLOW
ALKYL) DIMETHYL-, SALT WITH BENTONITE; (CLAY)
CAS:68953-58-2
RTECS #:UZ2996400
Fraction by Wt: <5%
OSHA PEL:10 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:XYLENE. VP:6.6 @ 68F. LD50:4.3 G/KG
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 16.85%
OSHA PEL:100 PPM; 150 STEL
ACGIH TLV:100 PPM; 150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PHOSPHORIC ACID, ZINC SALT; (ZINC PHOSPHATE)
CAS:7779-90-0
RTECS #:TD0590000
Fraction by Wt: <20%
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:VAP/SPRAY MIST CAN BE HARMFUL.
IRRITATING TO EYES, SKIN, NOSE & THROAT. EXCESSIVE INHAL CAN CAUSE
HDCH, NAUS OR DIZZ. RPTD/PRLNGD OCCUP OVEREXPOS TO SOLV IS ASSOC
W/PERM BRAIN & NERV SYS DAM. CAN BE H ARMFUL/FATAL IF SWALLOWED.
CAN BE HARMFUL IF INHALED/ABSORBED THRU SKIN. OVEREXPOS CAN DAM
CNS. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:OVEREXPOSURE OR INGESTION CAN CAUSE
LUNG, KIDNEY &/OR LIVER DAMAGE. OVEREXPOSURE CAN CAUSE SKIN & EYE
BURNS &/OR INJURY. SKIN & RESPIRATORY SENSITIZATION & ALLERGIC
REACTION SUCH AS RASH, HIV ES OR ASTHMA CAN OCCUR. CHEMICAL
PNEUMONIA. ASPIRATION HAZARD.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:IF OVEREXPOSURE TO VAPOR/SPRAY MIST; PROVIDE FRESH AIR.
IF BREATHING LABORED, GIVE O*2/ARTF RESP. SKIN:WASH THORO W/SOAP &
WATER. EYES:FLUSH IMMEDIATELY W/PLENTY OF WATER FOR AT LEAST 15
MINS & GET MD. INGEST:DRINK 1 OR 2 GLASSES OF WATER TO DILUTE. DO
NOT INDUCE VOMITING. CONSULT MD OR POISON CONTROL CENTER
IMMEDIATELY. TREAT SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:72.0F,22.2C
Lower Limits:1
Upper Limits:8
Extinguishing Media:FOAM, CO*2 & DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CLSD CONTRS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT. ISOLATE FROM HEAT, ELEC EQUIP, SPARKS & OPEN FLAME.
VAPS MAY SPREAD LONG DISTANCES, CAUSE FLASH (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID BREATHING OF VAPORS. USE ABSORBENT
CLEANUP MATERIAL. PLACE IN SEPARATE CONTAINER. KEEP OUT OF SEWERS &
WATERWAYS. IF ENTRY IS THREATENED OR OCCURS, NOTIFY LOCAL
AUTHORITIES. ELIMINATE ALL SOURCE S OF IGNITION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. AVOID STORAGE TEMPERATURES ABOVE 100F. KEEP CONTAINER CLOSED,
UPRIGHT WHEN NOT IN USE.
Other Precautions:DO NOT TAKE INTERNALLY. AVOID PRLNGD BRTHG OF
VAPORS/SPRAY MIST OR CONTACT W/SKIN & EYES. DESTROY CONTAMD LEATHER
& ABSORB SHOES WHICH CANNOT BE DECONTAMD. DO NOT WELD OR FLAME CUT
AN EMPTY CONTAINER. GROUND CONTAINERS WHEN POURING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA CERTIFIED RESP. FOR SPECIFIC CNDTNS,
REFER TO CURRENT NIOSH POCKET GUIDE TO CHEM HAZ. USE NIOSH/MSHA
APPRVD AIR-LINE RESP IN CONFINED/RESTRICTED VENT AREAS. REFER TO
29CFR, OSHA PARTS 1910 & 1915, FOR COATING OPERATIONS.
Ventilation:SUFFICIENT VENT, IN VOL & PATTERN, SHOULD BE PROVIDED TO
KEEP AIR CONTAM CONC BELOW TLV LIMIT. REMOVE WELDING (SUP DAT)
Other Protective Equipment:FULL PROTECTIVE CLOTHING & SPARK-PROOF
EQUIPMENT. EMERGENCY EYEWASH & DELUGE SHOWER .
Work Hygienic Practices:WASH THOROUGHLY BEFORE EATING, SMOKING OR USING
WASHROOM. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
EXPLO HAZ:FIRE OR IGNITE EXPLOSIVELY. VENT:OR FLAME CUTTING
DECOMPOSTION PRODUCTS. REFER TO 29 CFR, OSHA PARTS 1910 & 1915, FOR
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:1.39-1.63
Evaporation Rate & Reference:LOW:0.40 HIGH:1.60 BUAC=1
Appearance and Odor:LIQUID; SOLVENT ODOR.
Percent Volatiles by Volume:63
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS & ALKALIES.
Stability Condition to Avoid:HEAT, OPEN FLAME, ARC OR SPARKS.
Hazardous Decomposition Products:BY FIRE, BURNING OR WELDING:CARBON
MONOXIDE & CARBON DIOXIDE, IRON OXIDE FUMES, AMMONIA & ALDEHYDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN SEPARATE, CLOSED METAL CONTAINER IN
ACCORDANCE W/ALL APPLICABLE REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:5783WA
CAGE:0872X
CAGE:0872X
CAGE:49956
============= Composition/Information on Ingredients =============
Ingred Name:KRYPTON 85
===================== Hazards Identification =====================
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
======================= First Aid Measures =======================
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
===================== Fire Fighting Measures =====================
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
================== Accidental Release Measures ==================
======================Handling and Storage ======================
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
SOURCE OF DATA-EXAM OF STOCK IN WHSE. SAFETY & HEALTH DATA DEVELOPED BY
DGSC-STF.
================== Physical/Chemical Properties ==================
HCC:A2
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-IN ACCORDANCE WITH
DOD REGULATIONS AND FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:03BK071 MIL-C-85285B 17038 TYPE I
Preparer's Name:MIKE SMITH
CAGE:FO129
CAGE:FO129
CAGE:33461
============= Composition/Information on Ingredients =============
Ingred Name:BUTYL ACETATE (N-BUTYL ACETATE) *96-4*
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 10%
Other REC Limits:150 PPM
OSHA PEL:710 MG/CUM
ACGIH TLV:713 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL 3-ETHOXYPROPIONATE, PROPANOIC ACID, 3-ETHOXY-, ETHYL
ESTER *96-4*
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: 15%
Ingred Name:SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC, HIGH FLASH
AROMATIC NAPHTHA, C8&10 AROMATIC HYDROCARBON *96-4*
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: <1%
Ingred Name:2-BUTOXYETHANOL (ETHYLENE GLYCOL MONOBUTYL ETHER), BUTYL
CELLOSOLVE, BUTYL GLYCOL, GLYCOL ETHER EB *96-4*
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: <0.1%
Other REC Limits:25 PPM (SKIN)
OSHA PEL:50 PPM (SKIN)
ACGIH TLV:25 PPM (SKIN)
Ingred Name:2-HEPTANONE, METHYL N-AMYL KETONE *96-4*
CAS:110-43-0
RTECS #:MJ5075000
Fraction by Wt: 5%
Other REC Limits:50 PPM
OSHA PEL:465 MG/CUM
ACGIH TLV:233 MG/CUM
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *96-4*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: <0.1%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE *96-4*
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: <0.1%
Other REC Limits:100 PPM
OSHA PEL:435 MG/CUM
ACGIH TLV:434 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (IARC CARC- GROUP 3) *96-4*
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <1%
Other REC Limits:375 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:2-ETHYLHEXYL ACRYLATE, ETHYL ACRYLATE POLYMER *96-4*
CAS:26376-86-3
Fraction by Wt: <1%
Ingred Name:2,4-PENTANEDIONE, ACETYLACETONE
*96-4*
CAS:123-54-6
RTECS #:SA1925000
Fraction by Wt: <5%
Ingred Name:DIETHYLENE GLYCOL BUTYL ETHER ACETATE, ETHANOL, 2-
(2-BUTOXYETHOXY), BUTYL CARBITOL ACETATE
CAS:124-17-4
RTECS #:KJ9275000
Fraction by Wt: <5%
Ingred Name:ANTI MAR AGENT
Fraction by Wt: <1%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY TRACT
IRRITATION, CNS DEPRESSION. SKIN/EYES: IRRITATION. INGESTION:
IRRITATION & CORROSIVE ACTION IN THE MOUTH, STOMACH TISSUE &
DIGESTIVE TRACT. VOMITING MAY CAUSE ASPIRATION, RESULTING IN
CHEMICAL PNEUMONITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, STAGGERING
GAIT, CONFUSION, UNCONSCIOUSNESS, COMA, SWELLING, REDNESS, RASH,
TEARING, STINGING SENSATION, DRYING, DEFATTING, CRACKING, BREATHING
DIFFICULTY, ASTHMA/ALLE RGIC RESPONSES.
Medical Cond Aggravated by Exposure:ASTHMA & OTHER RESPIRATORY
DISORDERS, SKIN ALLERGIES, ECZEMA, DERMATITIS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SKIN: WASH THOROUGHLY W/SOAP
& WATER. EYES: WASH W/LUKEWARM WATER (LOW PRESSURE) FOR 15 MINS.
INGESTION: DON'T INDUCE VOMITING. DON'T GIVE ANYTHING TO AN
UNCONSCIOUS P ERSON. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:45F
Lower Limits:0.76
Upper Limits:11.4
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG,
WATER SPRAY.
Fire Fighting Procedures:WEAR SCBA & FULL EQUIPMENT. USE WATER TO COOL
CONTAINERS.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT & OTHER IGNITION SOURCES. CLOSED CONTAINERS MAY EXPLODE
DUE TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE/VENTILATE AREA. REMOVE IGNITION
SOURCES. CONTAIN & REMOVE W/INERT ABSORBANT & NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID HIGH TEMP, FIRE & OTHER IGNITION
SOURCES. STORE IN TIGHTLY CLOSED CONTAINERS.
Other Precautions:KEEP CONTAINERS TIGHT & UPRIGHT TO PREVENT LEAKAGE.
AVOID BREATHING VAPORS/SPRAY MIST & CONTACT W/SKIN & EYES. DON'T
TAKE INTERNALLY. SMOKE IN SMOKING AREA ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRATOR RECOMMENDED/APPROVED FOR USE IN
AN ORGANIC VAPOR ENVIRONMENT/FRESH AIR SUPPLIED RESPIRATOR.
Ventilation:EXHAUST VENTILATION.
Other Protective Equipment:FACE SHIELDS W/SPLASH GUARDS, LONG SLEEVE,
LONG LEG CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING & BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:230-475F
Vapor Density:>1
Spec Gravity:1.06002
VOC Pounds/Gallon:345
Evaporation Rate & Reference:(N-BU AC=1): 0.43
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK LIQUID W/SOLVENT ODOR.
Percent Volatiles by Volume:38.2
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, ELECTRICAL EQUIPMENT, SPARKS, OPEN
FLAMES & OTHER IGNITION SOURCES.
Hazardous Decomposition Products:HIGH HEAT/TEMP: CO, CO2 & OXIDES OF
NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. EMPTY CONTAINERS MUST BE HANDLED W/CARE, DUE TO
PRODUCT RESIDUE & FLAMMABLE VAPORS. DON'T INCINERATE CLOSED
CONTAINERS. D001, F003, F005.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ETHYLENE GLYCOL
Preparer's Name:MIKE HOEFLER
CAGE:GREA1
CAGE:GREA1
CAGE:2P121
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA III)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 100%
OSHA PEL:50 PPM, C
ACGIH TLV:50 PPM, VAPOR, C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE/SKIN: CONTACT CAUSES MODERATE
IRRITATION. MAY BE HARMFUL IF ABSORBED THROUGH SKIN. INHAL:MAY BE
HARMFUL/FATAL IF INHALED. INGEST:MAY BE HARMFUL/FATAL IF SWALLOWED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:IMMED FLUSH W/PLENTY OF CLEAN RUNNING WATER FOR AT LEAST
15 MINS. GET MED ATTN. SKIN:FLUSH W/PLENTY OF CLEAN, RUNNING WATER.
REMOVE CONTAMD CLTHG/SHOES. IF IRRIT OCCURS/PERSISTS, GET MED ATTN.
IN GEST:DRINK A GLASS OF WATER & INDUCE VOM IMMED, AS DIRECTED BY
MED PERS. THEN GIVE LGE QTY OF MILK/WATER TO DRINK & TRANSPORT TO
HOSP. NEVER GIVE ANYTHING BY MOUTH TO AN UNCON PERS. INHAL: (SUP
DAT)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:232F,111C
Lower Limits:3.2%
Extinguishing Media:FOAM, CARBON DIOXIDE & DRY CHEMICALS. A WATER "FOG"
MAY BE USED FOR FIRE FIGHTING.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . A WATER SPRAY SHOULD BE USED TO COOL
CONTAINERS ONLY.
Unusual Fire/Explosion Hazard:MAY PRODUCE HAZARDOUS FUMES OR HAZARDOUS
DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILLED LIQ. (FOR SMALL SPILLS, ADD
DRY MATL TO CONTAIN). WEARING RECOM PROT EQUIP, REMOVE BULK OF LIQ.
ADD DRY MATL TO ABSORB REMAINIG LIQ; PICK UP & CONTAINERIZE FOR
RECOVERY/DISPOSAL. FLUSH AREA W/WATER TO REMOVE RESIDUES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY AREA AWAY FROM
HEAT, SPARKS & OPEN FLAME. FOR INDUS USE ONLY. USE W/ADEQ VENT.
KEEP CONTR TIGHTLY CLSED WHEN NOT IN USE.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. PROTECT EYES, SKIN &
CLOTHING FROM CONTACT W/PRODUCT. DO NOT BREATHE VAPOR, MIST OR
SPRAY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF THE OSHA-PEL IS EXCEEDED, A NIOSH/MSHA
APPROVED RESPIRATOR W/AN ORGANIC VAPOR CARTRIDGE OR SUPPLIED AIR IS
REQUIRED.
Ventilation:LOCAL EXHAUST PREFERABLE. MECHANICAL (GENERAL) O.K.
Other Protective Equipment:RUBBER APRON & RUBBER BOOTS, EYEWASH &
SAFETY SHOWER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
FIRST AID PROC:IMMEDIATELY MOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTF RESP, PREFERABLY MOUTH TO MOUTH. IF BREATHING IS DIFFICULT,
GIVE OXYGEN. CALL MD. NOTE:THERE ARE REPORTS THAT INDICATE ETHYLEN
E GLYCOL IS VERY TOXIC WHEN INHALED IN PARTICULATE FORM (AS IN A
FINE SPRAY OR MIST). EYE PROT: BY ANSI Z87.1, 1979).
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:388F,198C
Spec Gravity:1.113 (H*2O=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS, HYDROSCOPIC LIQUID W/NO
CHARACTERISTIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:WHEN HEATED TO DECOMPOSITION, IT EMITS
TOXIC OXIDES OF CARBON PLUS ACRID SMOKE & IRRITATING FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:PROD, IF DISPOSED AS SHIPPED, IS NOT A HAZ WASTE
AS SPECIFIED IN 40CFR261. CONSULT STATE, LOCAL OR FEDERAL OFFICIALS
FOR PROPER DISPOSAL METHOD. WHEN EMPTY, THORO RINSE CONTR W/WATER
BEFORE DISPOSAL, RETURN TO MFR OR ANY OTHER INDUSTRIAL USE.
| 1 | gloves_mandatory |
=======================================================
Product ID: BOELUBE 70201, 70201-00
Cage: 18554
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 18554
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50:(ORAL,RAT) >20 GM/KG.
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: PROLONGED &/OR REPEATED INHALATION MAY CAUSE
IRRITATION TO MUCOUS MEMBRANES & RESPIRATORY PASSAGES. EYE:NOT A PRIMARY
IRRITANT. SKIN:NOT A PRIMARY IRRITANT. NOT A HUMAN SKIN SENSITIZER.
INGEST:NON-TOX IC. INHAL:BREATHING HIGH CONCENTRATIONSMAY CAUSE TEMPORARY
DISCOMFORT, IRRITATION TO MUCOUS MEMBRANES (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:& RESPIRATORY PASSAGES,
DIZZINESS OR NAUSEA.
Medical Cond Aggravated By Exposure: UNKNOWN.
First Aid: SKIN:WASH THOROUGHLY W/SOAP & WATER. EYES:FLUSH W/LARGE AMOUNTS
OF WATER FOR AT LEAST 15 MINUTES, LIFTING UPPER & LOWER LIDS
OCCASIONALLY. GET MEDICAL ATTENTION. INGEST:IMMEDIATELY DRINK TWO LARGE GLA
SSES OF WATER. GET MEDICAL ATTENTION. INHAL:REMOVE TO FRESH AIR. GET MEDICAL
ATTENTION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: PERSONS NOT WEARING PROT EQUIP SHOULD BE EXCLUDED
FROM AREA OF SPILL UNTIL CLEAN-UP HAS BEEN COMPLETED. STOP SPILL AT SOURCE
& DIKE AREA OF SPILL TO PREVENT SPREADING. PUMP LIQ TO SALVAGE TANK.
REMAIN ING LIQ MAY BE ABSORBED ON ABSORB MATL & (SUPDAT)
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISP MUST BE I/A/W FED, STATE & LOC REGS (FP N).
INCIN IS REC DISP METH FOR ALL CHEM WASTES, ALTHOUGH MATL MAY BE LANDFILLED
I/A/W ALL APPLIC REGS. THIS PROD, IF DISPOSED OF, IS NOT CONSIDERED A HAZ W
ASTE UNDER CURRENT RCRA REGS.
Handling And Storage Precautions: KEEP CONTAINER CLOSED WHEN NOT IN USE. DO NOT
STORE NEAR HEAT, SPARKS, FLAME OR STRONG OXIDANTS.
Other Precautions: THIS PRODUCT IS NOT KNOWN OR EXPECTED TO BE HAZARDOUS, BUT,
AS W/ALL CHEMICALS, HANDLE W/CARE.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: COC
Flash Point Text: 335F,168C
Extinguishing Media: DRY CHEMICAL, WATER FOG, REGULAR FOAM.
Fire Fighting Procedures: USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP (FP
N). WATER/FOAM MAY CAUSE FROTHING WHICH CAN BE VIOLENT, ESP IF SPRAYED INTO
CNTNRS OF HOT, BURNING LIQUID.
Unusual Fire/Explosion Hazard: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Control Measures
=======================================================
Respiratory Protection: CONCENTRATION IN AIR DETERMINES PROTECTION NEEDED. USE
ONLY NIOSH/MSHA APPROVED RESPIRATORS.
Ventilation: LOCAL EXHAUST IF NEEDED TO COMPLY W/EXPOSURE LIMIT &/OR FOR
ENCLOSED SPACES.
Other Protective Equipment: NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices: USE GOOD INDUSTRIAL HYGIENIC PRACTICES.
Supplemental Safety and Health: PH:607 (10% IN IPA/H*2O). SPILL PROC:SHOVELED
INTO CONTAINER. PREVENT RUN-OFF FROM ENTERING DRAINS, SEWERS OR STREAMS.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 374F,190C
M.P/F.P Text: 110F,43C
Vapor Pres: 1 @ 68F
Vapor Density: >1 HVR/AIR
Spec Gravity: 0.32-0.85
PH: SUPDAT
Solubility in Water: INSOLUBLE
Appearance and Odor: PINK SOLID; ODORLESS.
Percent Volatiles by Volume: <1
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: CONCENTRATED OXYGEN, CHLORINE, PERMANGANATES &
PERCHLORATES.
Hazardous Decomposition Products: ASPHYXIANTS I.E., SMOKE, CARBON MONOXIDE &
CARBON DIOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: BOELUBE 70201, 70201-00
Cage: 18554
Company Name: THE ORELUBE CORP
Street: 201 E BETHPAGE RD
Zipcode: 11803-4202
Label Required IND: Y
Date Of Label Review: 04/24/1995
Status Code: C
Label Date: 04/24/1995
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE:INHAL:BREATHING HIGH CONCENTRATIONS
MAY CAUSE TEMPORARY DISCOMFORT, IRRITATION TO MUCOUS MEMBRANES &
RESPIRATORY PASSAGES, DIZZINESS OR NAUSEA. CHRONIC:NONE LISTED BY
MANUFACTURER.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HD3404, CURING AGENT.
CAGE:14347
CAGE:12405
CAGE:14347
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENAMINES PERCENTAGE IS 90-100%
===================== Hazards Identification =====================
Effects of Overexposure:DISAGREEABLE ODOR&IRRITATION OF RESP.TRACT MAY
CAUSE SENSITIZATION.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRES AIR&CONSULT MD. EYE:REMOVE EXCESS&FLUSH
EYES IMMEDIATELY FOR AT LEAST 15 MIN.REPEAT IF NEC.CALL MD IF IRRIT
PERSISTS. SKIN:REMOVE EXCESS&WAS W/SOAP&WATER.CONSULT MD IF IRRIT
PERSI STS.
===================== Fire Fighting Measures =====================
Flash Point:265F COC
Extinguishing Media:CO*2, DRY CHEMICALS, FOAM, WATER SPRAY OR FOG
Fire Fighting Procedures:FIREFGHTRS WEAR SELF-CONTAINED BREATHING
APPARATUS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES,AND PROVIDE ADEQUATE
VENTILATION.COVER SPILL W/ABSORBENT MATERIAL AND REMOVE TO WASTE
CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS IN A COOL,
DRY AREA AWAY FROM HEAT, SPARKS & OPEN FLAMES. USE ONLY WITH
ADEQUATE VENTILATION.AVOID RPTD/PRLNGD SKIN CONTACT
Other Precautions:AVOID PRLNGD/RPTD BRTHNG OF VAPORS.HAVE RESPS
AVAILABLE SHLD VENT 60FPM.MECH.-EXPLSN PRF VENTLTN SYSTEM.
Other Protective Equipment:HYDROCARBON INSOL.APRONS,EYEWASH&SAFETY
Supplemental Safety and Health
VAPOR DENSITY IS HEAVIER THAN AIR.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:260 TO 290C
Evaporation Rate & Reference:SLOWER THAN ETHER
================= Stability and Reactivity Data =================
Hazardous Decomposition Products:THERMAL DECOMP MAY PRODUCE CO&CO*2.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE WITH FEDERAL, STATE, & LOCAL
ENVIRONMENTAL CONTROL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NITRIC ACID 16550, A198C212
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:NITRIC ACID (SARA 302/313) (CERCLA)
CAS:7697-37-2
RTECS #:QU5775000
Fraction by Wt: 69-7%
OSHA PEL:2 PPM
ACGIH TLV:2 PPM/4 STEL; 9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 29-31%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DANGER! STRONG OXIDIZER. CNTCT W/OTHER
MATL MAY CAUSE A FIRE. CORROSIVE. CAUSES EYE & SKIN BURNS. CAUSES
DIGESTIVE & RESP TRACT BURNS. ACUTE: EYE:CAUSES SEV EYE BURNS. MAY
CAUSE IRREVERSIBLE EYE INJUR Y. SKIN: MAY CAUSE SEV SKIN IRRIT.
CAUSES SKIN BURNS. MAY CAUSE DEEP, PENETRATING ULCERS OF THE SKIN.
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:INGEST: CAUSES GI TRACT BURNS. MAY
CAUSE PERFORATION OF THE DIGESTIVE TRACT. INHAL: MAY BE FATAL IF
INHALED. EFTS MAY BE DELAYED. MAY CAUSE IRRIT OF THE RESP TRACT
W/BURNING PAIN IN THE NOSE& THROAT, COUGHING, WHEEZING,
SHORTNESSOF BRTH & PULM EDEMA. CHRONIC: RPTD INHAL MAY CAUSE
CHRONIC BRONCHITIS. REPEATED EXPOS MAY CAUSE EROSION OF TEETH.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/PLENTY OF H*2O FOR AT LEAST 15 MIN, OCCASIONALLY
LIFTING THE UPPER & LOWER LIDS. GET MED AID IMMED. DO NOT ALLOW
VICTIM TO RUB/KEEP EYES CLSD. SKIN:FLUSH W/PLENTY OF SOAP & H*2O
FOR AT LE AST 15 MIN WHILE REMOVING CONTAMD CLTHG& SHOES. GET MED
AID IF IRRIT DEVELOPS/PERSISTS. WASH CLTHG BEFORE REUSE. INGEST:DO
NOT INDUCE VOMIT & SEEK IMMED MED ADVICE. INHAL:REMOVE FROM EXPOS
TO FRESH AI R IMMED. IF NOT BRTHG, GIVE ARTF RESP. IF BREATHING IS
DIFFICULT, GIVE OXYGEN. GET MEDICAL AID. NOTES TO MD:TREAT
SYMPTOMATICALLY & SUPPORTIVELY. NO SPECIFIC ANTIDOTE EXISTS.
===================== Fire Fighting Measures =====================
Extinguishing Media:SUBSTANCE IS NONCOMBUSTIBLE; USE AGENT MOST
APPROPRIATE TO EXTINGUISH SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:GENERAL INFO: USE PROPER PERSONAL PROT
EQUIPMENT AS INDICATED IN PERS PROT EQUIP SECTION.
SPILLS/LEAKS:ABSORB SPILL W/INERT MATERIAL, (E.G., DRY SAND OR
EARTH), THEN PLACE INTO A CHEMICAL WASTE CONTAI NER. USE H*2O SPRAY
TO DISPERSE THE GAS/VAPOR.
Neutralizing Agent:SPILL WITH SODIUM BICABONATE.
======================Handling and Storage ======================
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION. STORE
IN A COOL, DRY, WELL-VENTILATED AREA AWAY FROM INCOMPATIBLE
SUBSTANCES.
Other Precautions:DO NOT GET ON SKIN OR IN EYES. DO NOT INGEST OR
INHALE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATORY REGULATIONS FOUND IN
29CFR 1010.134. ALWAYS USE A NIOSH-APPROVED RESPIRATOR WHEN
NECESSARY.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
AIRBORNE CONCENTRATIONS BELOW THE PERMISSIBLE EXPOSURE LIMITS.
FACESHIELD .
Other Protective Equipment:ANSI APPRVD EMER EYE WASH & DELUGE SHOWER .
WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:187F,86C
Melt/Freeze Pt:M.P/F.P Text:-44F,-42C
Vapor Pres:6.8
Spec Gravity:1.50
pH:1.0
Solubility in Water:COMPLETELY SOLUBLE
Appearance and Odor:CLEAR OR YELLOWISH TRANSPARENT LIQUID. STRONG ACRID
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NITRIC ACID REACTS W/OVER 150 CHEM COMBINATIONS. REFER TO NFPA FIRE
PROTECTION GUIDE FOR SPECIFICS. REACTS EXPLOSIVELY W/ORG MATLS &
COMBUSTIBLE MATLS.
Stability Condition to Avoid:HIGH TEMPERATURES, INCOMPATIBLE MATERIALS,
MOISTURE, REDUCING AGENTS.
Hazardous Decomposition Products:NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NITROGEN, 24073
CAGE:55371
CAGE:55371
============= Composition/Information on Ingredients =============
Ingred Name:NITROGEN
CAS:7727-37-9
RTECS #:QW9700000
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:ASPHYXIANT
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MATERIAL ACTS AS A SIMPLE
ASPHYXIANT BY DISPLACING AIR NECESSARY FOR LIFE. SYMPTOMS INCLUDE
RAPID RESPIRATION, MUSCULAR INCOORDINATION, FATIGUE, DIZZINESS,
NAUSEA, VOMITING, UNCONSCIOUSNESS AND DEATH. CHRONIC: NONE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMEDIATELY . EYES: IMMEDIATELY FLUSH
W/POTABLE WATER FOR A MINIMUM OF 15 MINUTES, SEEK ASSISTANCE FROM
MD . SKIN: FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD . INHAL:
IMMEDIATELY REMOVE VICTIM TO FRESH AIR.IF BREATHING HAS STOPPED,
GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, GIVE
OXYGEN. IN EVENT OF EXPOSURE, CONSULT MD. NOTE TO MD: NONE.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:USE WHAT IS APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . KEEP FIRE EXPOSED CYLINDERS COOL WITH WATER SPRAY. IF
POSSIBLE, STOP THE PRODUCT FLOW.
Unusual Fire/Explosion Hazard:CYLINDER RUPTURE MAY OCCUR UNDER FIRE
CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AND VENTILATE AREA. SHUT OFF SOURCE
IF POSSIBLE AND REMOVE SOURCE OF HEAT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:SECURE CYL WHEN USING TO PROTECT FROM
FALLING. USE SUITABLE HAND TRUCK TO REMOVE CYLS. STORE IN WELL
VENTD AREAS. KEEP VALVE PROT CAP ON CYLS (SUPDAT)
Other Precautions:PROTECT CNTNRS FROM PHYSICAL DAMAGE. DO NOT DEFACE
CYLINDERS OR LABELS. CYLINDERS SHOULD BE REFILLED BY QUALIFIED
PRODUCERS OF COMPRESSED GAS. SHIPMENT OF COMPRESSED GAS CYLINDER
WHICH HAS NOT BEEN FI LLED BY THE OWNER OR WITH (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN CASE OF LEAKAGE, USE NIOSH APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Ventilation:PROVIDE ADEQUATE GENERAL AND LOCAL EXHAUST VENTILATION TO
MAINTAIN CONCENTRATION BELOW EXPOSURE LIMITS.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
SAFETY SHOES WHEN HANDLING CYLINDERS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SOL IN H*2O: CM3/100CM3 H*2O 1.485. WASTE DISP METH: PLUGS OR CAPS
SECURED AND VALVE PROTECTION CAP IN PLACE. HNDLG/STOR PRECS: WHEN
NOT IN USE. OTHER PRECS: HIS/HER WRITTEN CONSENT IS A VIOLATION OF
FEDERAL LAW (49 CFR). CYLINDERS SHOULD BE TRANSPORTED IN SECURE
UPRIGHT POSITION IN A WELL VENTILATED TRUCK.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:-320F,-196C
Vapor Density:0.967
Spec Gravity:GAS
Evaporation Rate & Reference:GAS
Solubility in Water:SUPDAT
Appearance and Odor:COLORLESS, ODORLESS GAS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:STORAGE IN POORLY VENTILATED AREAS.
STORAGE NEAR A HEAT SOURCE.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:NON-RETURNABLE CNTNRS MUST NOT BE REFILLED.
DISPOSE OF NON-REFILLABLE CYLINDERS I/A/W FEDERAL, STATE & LOCAL
REGS. ALLOW GAS TO VENT SLOWLY TO ATMOSPHERE IN UNCONFINED AREA OR
EXHAUST HOOD. RETURN CYL INDERS TO SUPPLIER W/ANY VALVE OUTLET
(SUPDAT)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:H.P.-CORROSION RESIST. ALLOYS, G-30 (8130)
CAGE:FO136
CAGE:80798
CAGE:FO136
============= Composition/Information on Ingredients =============
Ingred Name:COBALT (SARA III)
CAS:7440-48-4
RTECS #:GF8750000
Fraction by Wt: 2.0%
OSHA PEL:0.1 MG/M3;AS CO
ACGIH TLV:0.05 MG/M3;DUST 9293
Ingred Name:CHROMIUM (SARA III)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 29.5%
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 1.0%
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
Fraction by Wt: 5.5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9293
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 43%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
===================== Hazards Identification =====================
Effects of Overexposure:INHALATION: IRRITATION TO SKIN/EYE & MUCOUS
MEMBRANES/ALLERGIC REACTIONS/DERMATITIS/COUGH/FEVER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. INGESTION: DRINK LARGE
QUANTITIES OF WATER. INDUCE VOMITING IF CONSCIOUS. SKIN: TREAT CUTS
& ABRASIONS WITH FIRST AID. WASH WITH SOAP & WATER. EYES: FLUSH
W/WATER. IF IRRITATION PERSISTS OBTAIN MEDICAL ASSISTANCE.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NONCOMBUSTIBLE
Fire Fighting Procedures:TO EXTINGUISH METAL POWDER FIRE USE DRY
SAND/DRY GRAPHITE.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SOLID FORM MATERIAL POSES NO SPECIAL CLEAN-UP
PROBLEMS. IF MATERIAL IS IN POWDER OR ST FORM, CLEAN-UP SHOULD BE
CONDUCTED W/VACUUM SYSTEM UTILIZING HIGH EFFIENCY PARTICULATE AIR
FILTRATION SYSTEM. MIN IMIZE AIRBORNE OF POWDER OR ST.
======================Handling and Storage ======================
Handling and Storage Precautions:PRODUCT MUST BE HANDLED ACCORDINGLY TO
THE SIZE, SHAPE & QTY OF MATERIAL INVOLVED. SOLID METALAY REQUIRE
USE OF HOISTS, CRANES, ETC.
Other Precautions:IN SOLID FORM THIS MATERIAL POSES NO SPECIAL STORAGE
PROBLEMS. STORE METAL POWDER IN A DRY AREA. DON'T STORE ADJACENT TO
MINAL ACIDS. KEEP AWAY FROM FLAMES & SOURCES OF IGNITION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATORS
Ventilation:LOCAL EXHAUST VENT CONTROL TO AIRBORNE DUST & FUME.
Other Protective Equipment:UNIFORMS/DISPOSABLE COVERALLS/SAFETY
SHOES/DON'T WEAR CONT.
Supplemental Safety and Health
MSDS DATE: 11/1/85. ALSO CONTAINS: TANTALUM (WW5505000) 2.0%, COPPER
(GL5325000) 2.0%, IRON (NO7400000) 15%, SILICON (VW04000) 1.0%,
TUNGSTEN (YO7175000) 2.5%. DON'T WEAR CONTACT LENSES
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:.297F
Vapor Density:2300
Solubility in Water:NONE
Appearance and Odor:SOLID, SILVER GRAY COLOR, NO ODOR.
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH MINERAL ACIDS, OXIDIZING AGENTS.
Stability Condition to Avoid:CONTACT W/ACIDS & OXIDIZERS MAY GENERATE
HYDROGEN GAS.
Hazardous Decomposition Products:ELEMENTAL METALS & METAL OXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:PRIOR TO DISPOSAL CONSIDER IF MATERIAL HAS
RECOVERY VALUE. STATE OR FEDERAL REGULATIONS REQUIRE SPECIFIC
LABELING, PACKING, STORAGE, TRANSPORTATION & DISPOSAL PROCEDURES.
CONTACT ENVIRONMENTAL ENGINEE R OR CONSULTANT FAMILIAR W/WASTE
DISPOSAL REGS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TURCO ALBRITE HEAVY
CAGE:D9808
CAGE:61102
CAGE:D9808
============= Composition/Information on Ingredients =============
Ingred Name:HYDROGEN FLUORIDE (SARA III)
CAS:7664-39-3
RTECS #:MW7875000
Fraction by Wt: 9.8%
OSHA PEL:3 PPM/6 STEL (F)
ACGIH TLV:C 3 PPM (F); 9192
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Effects of Overexposure:EYES:SEV IRRIT,MAY DAMAGE PERMNTLY;SKIN:MAY
CAUSE SEV PAINFUL BURNS;ING:*SEE OTHER PRECAUTIONS*
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER,15-30 MIN.OBTAIN MED ATTN;SKIN:FLUSH W/LG
QTY OF WATER.REMOVE CONTAMINATED CLOTHING.GET MD HELP;ING:DO NOT
INDUCE VOMITING.GIVE WATER/MILK.GET MED ATTN IMMEDIATELY;INH:REMOVE
TO FRE SH AIR.KEEP PERSON WARM/QUIET.GET MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:CO*2,WATER (MATL IS NON-FLAMMABLE)
Fire Fighting Procedures:WEAR GAS MASK.KEEP OFF CLOTHING.KEEP
CONTAINERS COOL
Unusual Fire/Explosion Hazard:THERMAL DECOMP.MAY EMIT FLUORINE GAS
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL NEUTRALIZE ACID AND ABSORB ON
ABSORBENT MATERIAL AND PLACE IN SEALABLE CONTAINER
======================Handling and Storage ======================
Handling and Storage Precautions:TRANSPORT & STORE IN CLOSED CONTAINERS
AT TEMPERATURES BETWEEN 32F & 130F.
Other Precautions:ING:IMMED SEV TISSUE DAMAGE OF ESOPHAGUS &
MOUTH;INH:SEV BURNS OF RESP TRACT
============= Exposure Controls/Personal Protection =============
Respiratory Protection:APPROVED RESPIRATOR W/CANISTER IF OVER TLV
Ventilation:MECHANICAL(GEN)
Other Protective Equipment:HELMET,FACE SHIELD,CHEM SUIT,RUBBER BOOTS
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:212F
Vapor Pres:25
Vapor Density:>1.0
Spec Gravity:1.04
Evaporation Rate & Reference:>1.0(BU ACETATE)
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID
Percent Volatiles by Volume:90
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS & CAUSTIC MATLS.
Hazardous Decomposition Products:FLUORINE GAS
Conditions to Avoid Polymerization:UNK
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE CONTAINER W/NEUTRALIZED ACID IN AN
APPROVED LANDFILL ACCORDING TO FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:30102404, DALIC SOLUTION NO 4 ETCHING & (SUPDAT)
Preparer's Name:WERNER A. KHRENESCHOEIDER
CAGE:DO645
CAGE:11924
CAGE:DO645
============= Composition/Information on Ingredients =============
Ingred Name:HYDROCHLORIC ACID; (HYDROGEN CHLORIDE) (SARA 302/313)
(CERCLA)
CAS:7647-01-0
RTECS #:MW4025000
Fraction by Wt: 5-10%
OSHA PEL:5 PPM, C
ACGIH TLV:5 PPM, C
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 60-100%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:FIRST AID PROC: PROD, NUMBER & CNDTN OF CASUALTIES, WHAT IS
RTECS #:9999999ZZ
Ingred Name:ING 3:PARTY HANGS UP! HAVE QUALIFIED PERSON RENDER PROMPT
FIRST AID TO VICTIM. TIME IS VITALLY IMPORTANT. REMOVE (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: FROM CONTAMD AREA TO CLEAN, QUIET, VENTD AREA. CALM
& REASSURE. EYE:HOLD LIDS APART & MOVE EYES SLOWLY IN (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:EVERY DIRECTION; IMMED FLUSH W/PLENTY OF TEPID WATER
FOR AT LST 15 MIN. SKIN:IMMED FLUSH W/PLENTY OF WATER (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: FOR AT LST 15 MIN WHILE REMOVING CONTAMD CLTHG &
SHOES AS QUICKLY AS POSS. INHAL:REMOVE TO FRESH AIR. LAY (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:VICTIM DOWN, LEGS RAISED. LOOSEN TIGHT CLTHG. COVER
W/BLANKET. IF NOT BRTHG GIVE ARTF RESP. IF BRTHG DFCLT,(ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:GIVE LOW PRESS OXYGEN. INGEST:DO NOT INDUCE VOMIT.
IMMED GIVE LG QTYS OF WATER/MILK. IF VOMIT OCCURS, GIVE(ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: FLUIDS REPEATEDLY. NEVER GIVE ANYTHING BY MOUTH TO
UNCON PERSON. CHRONIC OVEREXP: REMOVE FROM FURTHER EXPOS.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: H*2O INTO SUITABLE PLASTIC CNTNR. SHIP TO
APPRVD TREATMENT/DISP FACILITY. FLUSH SPILL AREA W/PLENTY OF H*2O.
RTECS #:9999999ZZ
Ingred Name:HNDLG/STOR PRECS: THOROUGHLY AFTER HNDLG. KEEP CNTNR
TIGHTLY CLSD IN UPRIGHT POSITION. STORE AT 50-90F AWAY (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: FROM INCOMPAT MATLS. PROTECT CNTNRS AGAINST SPILL &
PHYSICAL INJURY. DO NOT REMOVE OR DEFACE CNTNR LABELS.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:AIR RESP W/FULL FACEPIECE; ANY SCBA W/FULL
FACEPIECE; ANY AIR-PURIFYING FULL-FACEPIECE RESP W/ACID GAS(ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:CARTRIDGES; ANY FULL-FACEPIECE CHEM CARTRIDGE RESP
W/ACID GAS CARTRIDGES; ANY POWERED AIR-PURIFYING RESP (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:W/ACID GAS CARTRIDGES. EMER/PLANNED ENTRY INTO
UNKNOWN CONCS OR IDLH CNDTNS:USE ANY SCBA W/FULL FACEPIECE(ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: & OPERATED IN PRESS-DEMAND OR OTHER POS-PRESS MODE;
ANY SUPPLIED-AIR RESP W/FULL FACEPIECE & OPERATED (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:IN PRESS-DEMAND OR OTHER POS-PRESS MODE IN
COMBINATION W/AUXILIARY SCBA OPERATED IN PRESS-DEMAND OR OTHER(ING
19)
RTECS #:9999999ZZ
Ingred Name:ING 18: POS-PRESS MODE. ESCAPE: USE ANY AIR-PURIFYING FULL
FACEPIECE RESP (GAS MASK) W/ACID GAS CANISTER; ANY (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19: APPROP ESCAPE-TYPE SCBA.
RTECS #:9999999ZZ
Ingred Name:EYE PROT: & FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DANGER! CAUSES SEVERE IRRIT & CORR OF
SKIN, EYES & RESP SYSTEM. MAY CAUSE PERM EYE INJURY. EYES: PAIN,
TEARING, ABNORMAL INTOLERANCE TO LIGHT, ABNORMAL COLLECTION OF
FLUID IN MUC MEMB OF EYELIDS, CORN EAL DMG/DESTRUCTION. SKIN:
IRRIT, INFLAM, PAINFUL BURNS W/WHITE STAINS, PAINFUL BLISTERS.
INHAL: IRRIT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: OF MUC MEMBS, WATERING OF EYES,
SALIVATION, COUGH, DFCLTY BRTHG, BRONCHITIS, HDCH, FATG, GIDD,
NAUS, PAINFUL ULCERATION OF NOSE & THROAT, CHEM PNEUM, PULM EDEMA,
COMA. INGEST: IRRIT & BURNIN G PAIN IN MOUTH, THROAT & STOM, PAIN
INSWALLOWING, INTENSE THIRST, ULCERATION OF MUC MEMBS, STOM CRAMPS,
NAUS, (SUPDAT)
Medical Cond Aggravated by Exposure:PREEXISTING RESPIRATORY DISORDERS,
PREEXISTING EYE AND SKIN CONDITIONS.
======================= First Aid Measures =======================
First Aid:FIRST AID PROVIDERS MUST TAKE PROPER PRECS FOR THEIR OWN SFTY
BEFORE ENTERING CONTAMD AREAS TO ASSIST CHEM ACCIDENT VICTIMS &
HNDLG THEIR CONTAMD CLTHG & EQUIP. ALWAYS HAVE ANOTHER PERSON IMMED
CALL E MER MED SERVICE, POIS CTL CTR, 911-OPERATOR, HOSPITAL, MD OR
OPHTHALMOLOGIST AS APPLIC. GIVE FOLLOWING INFO:LOCATION OF
& (ING 3)
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:ALL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:EXCESSIVE HEAT MAY CAUSE CONTAINERS TO
BURST AND GENERATE CORROSIVE VAPORS. CONTACT WITH COMMON METALS MAY
LIBERATE FLAMMABLE HYDROGEN GAS.
================== Accidental Release Measures ==================
Spill Release Procedures:NOTIFY YOUR FACILITY EMER COORDINATOR. DO NOT
RELS INTO SOIL, SEWER, STREAM, POND OR OTHER SOURCES OF DRINKING
WATER. PROVIDE MAX VENT. ELIM ALL IGNIT SOURCES. WEAR PROPER
PERSONAL PROT EQUIP. CAREFUL LY MOP UP OR VACUUM SPILL & TRIPLE
RINSE (ING 11)
Neutralizing Agent:SODIUM BICARBONATE, SODA ASH/SLAKED LIME.
======================Handling and Storage ======================
Handling and Storage Precautions:USE "BUDDY SYSTEM" WHEN WORKING
W/CHEMS. DO NOT GET IN EYES, ON SKIN, ON CLTHG. AVOID BRTHG VAP,
MIST OR GAS. USE W/ADEQ VENT. WASH (ING 12)
Other Precautions:TRIPLE RINSE CONTAINER CLEAN BEFORE DISCARDING. PUT
NOTHING ELSE IN THIS CONTAINER. DO NOT WEAR CONTACT LENSES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPRVD RESP REQD <50 PPM HYDROCHLORIC
ACID: ANY SUPPLIED-AIR RESP; ANY SCBA; ANY CHEM CARTRIDGE RESP
W/ACID GAS CARTRIDGES. <100 PPM HYDROCHLORIC ACID: USE ANY
SUPPLIED-AIR RESP OPERATED IN CONT INUOUS FLOW MODE; ANY SUPPLIED-
(ING 14)
Ventilation:LOCAL EXHAUST REQUIRED TO MEET PERMISSIBLE EXPOSURE LIMITS
(PEL).
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
IMPERVIOUS BOOTS, APRON, PROTECTIVE CLOTHING AS REQD BY JOB
CONDITIONS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO: ACTIVATING, 1024. SPEC GRAV: 1.115-1.125
(H*2O=1). EFTS OF OVEREXP: VOMIT, WEAK. MAY BE FOLLOWED BY ASPHY,
DELAYED ESOPHAGEAL OR GASTRIC PERFORATION. CHRONIC: EROSION OF TEET
H, JAW NECROSIS, BRONCH IRRIT, CHRONIC COUGH, BRONCH PNEUM, GI
DISTURBS ARE POSS. TARGET ORGANS: RESP SYS, SKIN, EYES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:<32F,<0C
Spec Gravity:SUPDAT
pH:0-1
Evaporation Rate & Reference:SLOWER (ETHYL ETHER=1)
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID; PUNGENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
METALS, STRONG BASES AND ACIDS, OXIDIZERS, NITRIC COMPOUNDS.
Stability Condition to Avoid:HEAT.
Hazardous Decomposition Products:HCL, H*2, CL*2, NA*2O.
==================== Disposal Considerations ====================
Waste Disposal Methods:SHIP TO APPROVED TREATMENT/DISPOSAL FACILITY.
DISPOSE OF ACCORDING TO LOCAL, STATE AND FEDERAL REGULATIONS. EPA
WASTE NUMBER D002.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:100-24 CAMEO WHITE, BRUTONE INTERIOR LATEX (SUPDAT)
CAGE:EO376
CAGE:EO376
CAGE:85520
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA 313) (CERCLA) % (WT): 1.08/3.40
CAS:107-21-1
RTECS #:KW2975000
OSHA PEL:N/K
ACGIH TLV:C 50 PPM,VAPOR; 9495
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:PIGMENT
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC CONTENT: 0.76 TO 1.37
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:BE INDUCED BY GENTLY PLACING TWO FINGERS INTO BACK
OF THE THROAT. IF POSSIBLE, DO NOT LEAVE VICTIM UNATTENDED.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:COMBINATION OF PARTICULATE & GAS & VAPOR. IN
CONFINED AREAS, USE (NIOSH/MSHA APPRVD) AIR LINE TYPE RESP(ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:OR HOODS. RESPIRATORY PROTECTION MAY ALSO BE
NECESSARY IN ANY LATER MANUFACTURING OPERATIONS IN WHICH THESE(ING
7)
RTECS #:9999999ZZ
Ingred Name:ING 6:PRODUCTS MAY BECOME AIRBORNE IN THE FORM OF VAPOR OR
DUST.
RTECS #:9999999ZZ
Ingred Name:VENT:RESPIRATOR TO PREVENT OVEREXPOSURE. PROVIDE GENERAL
DILUTION/LOCAL EXHAUST VENTILATION IN VOLUME & PATTERN (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:TO KEEP TLV OF MOST HAZ INGREDIENTS IN INGREDIENT
SECTION BELOW ACCEPTABLE LIMIT, LEL IN FIRE & EXPLOSION (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:HAZARD DATA SECTION STATED LIMIT AND TO REMOVE
DECOMPOSITION PRODUCTS DURING WELDING OR FLAME CUTTING ON (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:SURFACES COATED WITH THESE PRODUCTS.
RTECS #:9999999ZZ
Ingred Name:HYGIENE PRACT:IT UNTIL IT HAS BEEN PROPERLY LAUNDERED.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:REPORTS HAVE ASSOCIATED REPEATED AND
PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN AND NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING AND INHALING THE C ONTENTS MAY BE HARMFUL OR FATAL.
DO NOTBREATHE VAPORS OR SPRAY MIST. WEAR AN APPROPRIATE, PROPERLY
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:FITTED RESP (NIOSH/MSHA APPRVD) DURING
& AFTER APPLICATN UNLESS AIR MONITORING DEMONSTRATES VAP/MIST
LEVELS ARE BELOW APPLIC LIMS. FOLLOW RESP MFR'S DIRECTIONS FOR RESP
USE. BASED ON PRESENCE OF COMPONENT (1), CEILING LIMS OF
EMPLOYEE'S EXPOS TO THIS COMPONENT SHALL NOT EXCEED 125 MG/M3
DURING ANY PART(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/LUKE WARM H*2O FOR AT LEAST 15 MIN. SEEK MD
IMMED. SKIN:FLUSH WASH W/COPIOUS AMTS OF LUKE WARM H*2O. REMOVE
CONTAMD CLTHG PROMPTLY, CNTCT MD IMMED. INHAL:REMOVE EXPOS
INDIVIDUAL TO FRESH A IR. CNTCT MD IMMED. INGEST:NEVER GIVE
ANYTHING BY MOUTH TO UNCON PERS. IF VICTIM IS CONSCIOUS & ALERT,
VOMIT SHOULD BE INDUCED FOR INGEST FOR MORE THAN ONE SWALLOW (1-2
TABLESPOONS FOR AN (SUPDAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CONTAINERS EXPOSED TO INTENSE HEAT FROM
FIRES SHOULD BE COOLED WITH WATER TO PREVENT VAPOR PRESSURE BUILDUP
WHICH COULD RESULT IN CONTAINER RUPTURE.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING. DO NOT STORE ABOVE
120F. DO NOT TAKE INTERNALLY. CLOSE CONTAINER AFTER EACH USE. KEEP
OUT OF THE REACH OF CHILDREN!
Other Precautions:BRUNING PAINT COMPANY TAKES NO RESPONSIBILITY FOR
DETERMINING WHAT MEASURES ARE REQUIRED FOR PERSONAL PROTECTION IN
ANY SPECIFIC APPLICATION. THE GENERAL INFORMATION GIVEN SHOULD BE
USED WITH DIRECTIO NS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN OUTDOOR/OPEN AREAS, USE (NIOSH/MSHA APPRVD)
MECH FILTER RESP TO REMOVE SOILD AIRBORNE PARTICLES OF OVERSPRAY
DURING SPRAY APPLICATN. IN RESTRICTED VENT AREAS. USE (NIOSH/MSHA
APPRVD) CHEM-MECH FILT ERS DESIGNED TO REMOVE (ING 5)
Ventilation:USE VENT AS REQD TO CTL VAP CONC. AVOID PRLNG/RPTD BRTHG OF
VAPS. IF EXPOS EXCEEDS TLV, USE NIOSH/MSHA APPRVD (ING 8)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS THOROUGHLY BEFORE EATING & USING
WASHROOM. REMOVE CONTAMINATED CLOTHING IMMEDIATELY & DO NOT WEAR
(ING 12)
Supplemental Safety and Health
MFR'S TRADE NAME/PART #:FLAT WALL PAINT. % VOLAT 63.31-73.21. EFTS OF
OVEREXP:OF WORK DAY. BASED ON PRESENCE OF COMPONENT (1), THESE
PRODS CAN BE IRRITATING TO EYES. FIRST AID PROC:ADULT) PREFERABLY W
/SYRUP OF IPECAC UNDER DIRECTION FROM MD/POISON CENTER. IF SYRUP OF
IPECEC IS NOT AVAIL, VOMIT CAN (ING 4)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:17.0 @ 68F
Vapor Density:HVR/AIR
Spec Gravity:1.23-1.35
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Solubility in Water:10.3 TO 11.3
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
THESE PRODUCTS ARE INCOMPATIBLE WITH STRONG ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY PRDCE HAZ FUMES WHEN HEATED TO
DECOMP. FUMES MAY CONTAIN CARBON MONOXIDE, CARBON DIOXIDE & OXIDES
OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT FLUSH TO SEWER, WATERSHED OR WATERWAY.
DISPOSE OF THESE PRODUCTS IN ACCORDANCE WITH APPLICABLE LOCAL,
COUNTY, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:GP250AFH
CAGE:S5945
CAGE:0REV0
CAGE:S5945
============= Composition/Information on Ingredients =============
Ingred Name:ALLOYS; (ALLOYS COMPOSED OF INGS 2 - 7)
Fraction by Wt: 33.3%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VANADIUM (SARA 313)
CAS:7440-62-2
RTECS #:YW1355000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM
CAS:7440-32-6
RTECS #:XR1700000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CHROMIUM (SARA 313) (CERCLA)
CAS:7440-47-3
RTECS #:GB4200000
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:COBALT (SARA 313)
CAS:7440-48-4
RTECS #:GF8750000
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.02 MG/M3
Ingred Name:NICKEL (SARA 313) (CERCLA)
CAS:7440-02-0
RTECS #:QR5950000
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:ZIRCONIUM
CAS:7440-67-7
RTECS #:ZH7070000
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3;10 STEL
Ingred Name:NICKEL (II) HYDROXIDE; (NICKEL HYDROXIDE) (NI(OH)2) (SARA
313) (CERCLA)
CAS:12054-48-7
RTECS #:QR7040000
Fraction by Wt: 22.8%
OSHA PEL:1 MG/M3 (NI)
ACGIH TLV:0.1 MG/M3 (NI)
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:30% KOH/LIOH MIXTURE (CONSISTING OF INGS 10 & 11)
RTECS #:9999999ZZ
Fraction by Wt: 11.4%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POTASSIUM HYDROXIDE (CERCLA)
CAS:1310-58-3
RTECS #:TT2100000
OSHA PEL:2 MG/M3, C
ACGIH TLV:2 MG/M3, C
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:LITHIUM HYDROXIDE
CAS:1310-65-2
RTECS #:OJ6307070
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Explanation of Carcinogenicity:COBALT:IARC MONOGRAPHS ON EVAL OF CARCIN
RISK OF CHEMS TO MAN, VOL 52, PG 363, 1991:GRP 2B. ANIMAL:PULM
FIBROSIS(SUPDAT)
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . SKIN:IF ELECTROLYTE
LEAKAGE OCCURS & MAKES CONTACT W/SKIN, WASH IMMEDIATELY. EYES:IF
ELECTR OLYTE COMES INTO CONTACT W/EYES, WASH W/COPIOUS AMOUNTS OF
WATER FOR AT LEAST 15 MINUTES, & CONTACT MD.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:BATTERIES THAT ARE LEAKING SHOULD BE HANDLED
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:BATTERIES IN CHARGED STATE SHOULD BE
HANDLED & STORED CAREFULLY TO AVOID SHORT CIRCUITS.
Other Precautions:DO NOT STORE IN DISORDERLY FASHION, OR ALLOW METAL
OBJECTS TO BE MIXED W/STORED BATTERIES. NEVER DISASSEMBLE A
BATTERY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NOT APPLICABLE.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLAN OF CARCIN:(BLOOD EFTS). NICKEL:IARC MONOGRAPHS ON EVAL OF CARCIN
RISK OF CHEMS TO MAN, VOL 49, PG 257, 1990:GRP 2B. NTP 7TH ANNUAL
RPT ON CARCINS, 1994:ANTIC TO BE CARCIN. HUMAN:LUNGS, NASAL CA
VITIES. NICKEL HYDROXIDE:NTP 7TH ANNUALRPT ON CARCINS, 1994:ANTIC
TO BE CARCIN. ANIMAL:LUNGS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BUFFER SALTS PH 5 THRU PH 8, PHA-79, PART A
Kit Part:Y
CAGE:29907
CAGE:29907
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM PHOSPHATE, MONOBASIC (OR POTASSIUM DIHYDROGEN
PHOSPHATE); (INORGANIC SALT)
CAS:7778-77-0
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:NO HARMFUL EFFECTS EFFECTS
INDICATED FROM AVAILABLE INFORMATION. CHRONIC:PROLONGED SKIN
CONTACT WITH BULK POWDER HANDLING COULD CAUSE SKIN IRRITATION OR
ALLERGIC REACTION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PROLONGED SKIN CONTACT WITH BULK
POWDER HANDLING COULD CAUSE SKIN IRRITATION OR ALLERGIC REACTION.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ASSISTANCE IF ANY ADVERSE EFFECTS SHOULD DEVELOP.
EYES:FLUSH THOROUGH WITH COLD WATER FOR AT LEAST 15 MINUTES.
SKIN:WASH WITH SOAP & COLD WATER. INHALATION:REMOVE TO FRESH AIR.
INGESTION:I F CONSCIOUS INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:USE ANY SUITABLE MEDIA FOR SURROUNDING AREA.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP POWDER INTO CONTAINER. CLEAN SPILL AREA
WITH WATER. IF PREPARED BUFFER SOLUTION IS SPILLED NEUTRALIZE AND
MOP AREA.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AS MATL IS HYGROSCOPIC, STORE IN COOL,
DRY PLACE W/CNTNR TIGHTLY CLSD. OMEGA BUFFERS ARE MFRD & FORMULATED
FOR LAB USE ONLY & REQ NO SPECIAL (SUPDAT)
Other Precautions:FOLLOWING SPECIAL HANDLING INFORMATION PERTAINS ONLY
TO BULK POWDER HANDLING:DO NOT BREATHE DUST. DO NOT GET IN EYES.
AVOID PROLONGED OR REPEATED SKIN CONTACT. DO NOT TAKE INTERNALLY.
STORE AT CONTROL LED ROOM TEMPERATURE IN DRY LOCATIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE DUST CONCENTRATION IS HIGH USE
APPROPRIATE NIOSH APPROVED DUST RESPIRATOR. WEAR NIOSH APPROVED
DUST RESPIRATOR WHEN EXPOSED TO BU LK POWDER HANDLING.
Ventilation:USE ADEQUATE GENERAL OR LOCAL VENTILATION TO KEEP FUME &
DUST LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . WEAR FULL COVER CLTHG WHEN EXPOS TO (SUPDAT)
Work Hygienic Practices:WASH WITH COLD WATER AFTER USE.
Supplemental Safety and Health
NOTE:PROD IS BLENDED MIX OF TWO (2) SEPARATE COMPONENTS. THIS IS
REFLECTED BY PART A & PART B COMBINED IN THIS PACKAGE. HNDLG/STOR
PROC:HNDLG, LABELLING/MARKINGS. OMEGA BUFFERS ARE NOT TO BE TAKEN
INT ERNALLY. MFR'S BUFFER PRODS ARE SAFE FOR SHIPMENT BY AIR,
SEA/GROUND TRANSPORTATION. OTHER PROT EQUIP:BULK PWDR HNDLG.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:752F,400C
Spec Gravity:2.34 (H*2O=1)
Solubility in Water:18% BY WT AT 20C.
Appearance and Odor:COLORLESS GRANULAR OR CRYSTALLINE POWDER; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:NEUTRALIZE BUFFER SOLUTIONS BEFORE DISPOSAL.
DISPOSE AT APPROVED "SITE". NOTE:DISPOSE OF ALL WASTES I/A/W
FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:0872B1 PRO-SEAL 872 B-1/2 BASE COMPOUND
Kit Part:Y
CAGE:83574
CAGE:83574
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTANONE (METHYL ETHYL KETONE) (MEK)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: <5%
Other REC Limits:590 MG/CUM
OSHA PEL:200 PPM
ACGIH TLV:590 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TITANIUM DIOXIDE, TIO2 (SUSPECTED ANIMAL CARCINOGEN, IARC
GROUP 3) *95-4*
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 5%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:CALCIUM CARBONATE, DOMOLITE, LIMESTONE, WHITING
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 10%
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:ALUMINUM (POWDER) *95-4*
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: <5%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:TOLUENE (IARC CARC- GROUP 3) *95-4*
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 5%
Other REC Limits:375 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:THIOL TERMINATED POLYETHER, POLYDITHIOETER (OR LIQ.
POLYSULFIDE POLYMER) *95-4*
CAS:68611-50-7
Ingred Name:CATALYST AMORPHOUS SILICA*95-4*
CAS:67762-90-7
Ingred Name:PHENOLIC RESIN POWDER
Ingred Name:VOLATILE ORGANIC CONTENT: 66 GR/L COMBINED PART A & B
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TOLUENE-EYES: BURNING. SKIN:
DERMATITIS. INHALATION: MAY CAUSE LIVER & KIDNEY DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:TOLUENE-BURNING, TEARING, REDDENING, DRYNESS,
CRACKING, DIZZINESS, DROWSINESS, FATIGUE, NAUSEA, DISTURBANCES IN
MEMORY, THINKING ABILITY, EMOTIONS, COORDINATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LUKE WARM WATER FOR 15 MINS. SKIN: WASH W/SOAP
& WATER. INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION
IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:74F
Lower Limits:1
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER.
Fire Fighting Procedures:USE AIR SUPPLIED RESPIRATOR. USE WATER TO COOL
HEAT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:HIGH TEMP MAY CAUSE PRESSURE BUILDUP IN
CLOSED CONTAINER.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES. SCOOP INTO
CONTAINERS. CLEAN UP RESIDUE W/A SUITABLE SOLVENT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. DON'T
STORE >120F. GROUNDING & BONDING PROCEDURE SHOULD BE FOLLOWED WHEN
TRANSPORTING THIS MATERIAL.
Other Precautions:EMPTY DRUMS MAY CONTAIN EXPLOSIVE VAPORS. DON'T CUT,
PUNCTURE/WELD ON/NEAR DRUM. VAPORS OF THIS PRODUCT ARE > AIR & MAY
COLLECT IN LOW/CONFINED AREAS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN APPLYING TO PRODUCE AIRBORNE LEVEL IN
EXCESS OF TLV, USE AN ORGANIC VAPOR CARTRIDGE/AIR-SUPPLIED
RESPIRATOR.
Ventilation:GENERAL TO MAINTAIN VAPORS < TLV.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE
SMOKING/EATING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Density:>1
Spec Gravity:1.46
Appearance and Odor:WHITE PASTE
Percent Volatiles by Volume:14
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:OXIDES OF CARBON, SULFUR DIOXIDE,
TRACES OF HYDROGEN SULFIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. EPA NO D-001 & D-035 HAZARDOUS WASTE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ELECTRON VACUUM TUBES
CAGE:33173
CAGE:33173
============= Composition/Information on Ingredients =============
Ingred Name:TUNGSTEN
CAS:7440-33-7
RTECS #:YO7175000
Fraction by Wt: <98%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:RHENIUM
Fraction by Wt: <98%
Other REC Limits:NONE RECOMMENDED
Ingred Name:RHENIUM 187
Fraction by Wt: 2%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:PRODUCT'S LD50 (ORAL RAT) WAS NOT STATED
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Health Hazards Acute and Chronic:ACUTE: SKIN CONTACT WITH TUBE DURING
OPERATION MAY CAUSE THERMAL BURNS. CHRONIC:MFR GAVE NO INFORMATION
OF MSDS.
Effects of Overexposure:SKIN-PAIN, BURNS, BLISTERS, REDNESS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:NO EMERGENCY CARE ANTICIPATED. IF BURNED, SEE DOCTOR.
===================== Fire Fighting Measures =====================
Extinguishing Media:MATERIAL IS NON-FLAMMABLE
Fire Fighting Procedures:NONE.
Unusual Fire/Explosion Hazard:ELECTRON TUBES OPERATE UNDER HIGH VACUUM
AND IMPLOSION COULD OCCUR AT HIGH TEMPERATURES DURING FIRES OR
DURING DISPOSAL PROCEDURES.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE.
Ventilation:NONE.
Other Protective Equipment:NONE.
Work Hygienic Practices:NONE.
Supplemental Safety and Health
HEATER WIRE FILAMENTS CONTAIN 2% RHENIUM 187 (SPECIFIC ACTIVITY 0.00445
UCI/GRAM) AND THE BALANCE IS TUNGSTEN AND RHENIUM 185 (NOT
RADIOACTIVE). THE CALCULATED SPECIFIC ACTIVITY OF THE FILAMENT IS
0.0 00089 UCI/GRAM. THE MIL-HBDK-600 SPECIFIES SPECIFIC ACTIVITY
MUST EXCEED 0.002 UCI TO BE RADIOACTIVE; THIS TUBE IS NOT.
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NONE
Solubility in Water:NONE.
Appearance and Odor:GLASS ENVELOPE; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:INK JET 51626A REFILL STATION, RF40A
CAGE:79981
CAGE:79981
============= Composition/Information on Ingredients =============
Ingred Name:2-PYRROLIDONE; (N-METHYL PYRROLIDONE)
CAS:616-45-5
RTECS #:UY5715000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:1,4-BUTANEDIOL
CAS:110-63-4
RTECS #:EK0525000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: MAY CAUSE SLIGHT
IRRITATION, REDNESS AND BLURRED VISION. SKIN: WILL CAUSE TEMPORARY
SKIN DISCOLORATION. INGESTION: HARMFUL IF SWALLOWED. CHRONIC: NONE
SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH POTABLE WATER FOR AT LEAST 15 MINUTES. SEE
MD . SKIN: FLUSH WITH COPIOUS AMOUNTS OF WATER. SEE MD .
INHALATION: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE OXYGEN OR
ARTI FICIAL RESPIRATION) . INGESTION: GET MEDICAL ATTENTION
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:140F,60C
Extinguishing Media:WET OR DRY EXTINGUISHER.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:NOT APPLICABLE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH SKIN, EYES, AND
CLOTHING.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT APPLICABLE. USE NIOSH APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NOT APPLICABLE.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:1.01 (H*2O=1)
Solubility in Water:MISCIBLE
Appearance and Odor:PLASTIC REEFILL STATION W/ INK REFILL CARTRIDGE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NOT APPLICABLE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NOT APPLICABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTAMINATED ABSORBENT MAY BE DISPOSED OF IN
ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FA-1076
CAGE:79833
CAGE:79833
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Other REC Limits:590 MG/CUM
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ISOBUTYL KETONE (SARA III)
CAS:108-10-1
RTECS #:SA9275000
Other REC Limits:50 PPM
OSHA PEL:100 PPM/75 STEL
ACGIH TLV:50 PPM/75 STEL; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TETRAHYDROFURAN (SARA III)
CAS:109-99-9
RTECS #:LU5950000
Other REC Limits:200 PPM
OSHA PEL:200 PPM/250 STEL
ACGIH TLV:200 PPM/250STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NAUSEA, NARCOSIS, LIVER,
KIDNEY/NERVOUS SYSTEM DAMAGE, WEAKNESS, EYES/SKIN IRRITATION,
DRYNESS. CAN SEVERELY BURN EYES. INGESTION: MAY RESULT VOMITING &
DIARRHEA.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: NAUSEA, NARCOSIS, LIVER,
KIDNEY/NERVOUS SYSTEM DAMAGE, WEAKNESS, EYES/SKIN IRRITATION,
DRYNESS. CAN SEVERE BURN EYES. INGESTION: MAY RESULT IN VOMITING &
DIARRHEA.
Medical Cond Aggravated by Exposure:RESPIRATORY AILMENTS, MAY CAUSE
INJURY TO LIVER & KIDNEYS.
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & WATER. GET MEDICAL ATTENTION. EYES: FLUSH
ABUNDENTLY W/CLEAN WATER & REFER TO PHYSICIAN. INGESTION: DON'T
INDUCE VOMITING. REFER TO PHYSICIAN. INHALATION: REMOVE PATIENT TO
FRESH A IR OR GIVE OXYGEN. USE CPR IF PATIENT IS NOT BREATHING.
REFER TO PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:OC
Flash Point:4F
Lower Limits:1.4%
Upper Limits:11.8%
Extinguishing Media:CO2, FOAM, DRY CHEMICAL
Fire Fighting Procedures:NIOSH/MSHA APPROVED SCBA SHOULD BE WORN. USE
WATER SPRAY TO COOL FIRE EXPOSED STRUCTURES & DISPERSE VAPOR CLOUD
IF FIRE IS NOT PRESENT.
Unusual Fire/Explosion Hazard:VAPOR IS >AIR & MAY TRAVEL CONSIDERABLE
DISTANCE TO SOURCE OF IGNITION & FLASHBACK.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SPILL ON SAND, EARTH, VERMICULITE,
OIL-DRI, OR SOL-SPEED-DRI. SHOVEL ABSORBED MATERIAL INTO STEEL
CONTAINER & COVER. KEEP AREA CLEAN. CLEAN UP SPILLS IMMEDIATELY.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN APPROVED SOLVENT STORAGE
AREA. KEEP TIGHTLY CLOSED. KEEP AWAY FROM HEAT, OPEN FLAMES,
SPARKS, HOT SURFACES & OXIDIZING AGENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH-APPROVED ATMOSPHERE SUPPLYING OR AIR
PURIFYING RESPIRATOR FOR ORGANIC VAPORS AS REQUIRED TO KEEP <TLV.
Ventilation:MECHANICAL: EXPLOSION-PROOF EQUIPMENT. PROVIDE LOCAL
EXHAUST VENTILATION TO KEEP <TLV.
Other Protective Equipment:PROTECTIVE CLOTHING AS REQUIRED TO PREVENT
SKIN CONTACT.
Work Hygienic Practices:PRACTICE GOOD PERSONAL HYGIENE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:149F
Vapor Pres:78
Vapor Density:2.5
Spec Gravity:0.867
Appearance and Odor:LIGHT AMBER. SWEET PUNGENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, OPEN FLAMES, SPARKS, HOT SURFACES &
OXIDIZING AGENTS.
Hazardous Decomposition Products:OXIDES OF CARBON, NITROGEN ZINC,
SULFUR, HYDROGEN CHLORIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL CHEMICAL & SOLVENT WASTE DISPOSAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SHAMPOO-TEX (CARPET-TEX LINE)
CAGE:7L847
CAGE:7L847
============= Composition/Information on Ingredients =============
Ingred Name:DIPROPYLENE GLYCOL METHYL ETHER
CAS:34590-94-8
RTECS #:JM1575000
Fraction by Wt: 4%
OSHA PEL:100 PPM, S
ACGIH TLV:100 PPM;150 STEL, S
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGEST:GASTROINTESTINAL IRRITATION
W/NAUSEA, VOMITING & DIARRHEA. SKIN/EYES:MAY CAUSE IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O2/ARTF
RESP) . INGEST:GIVE WATER. INDUCE VOMITING. SKIN:WASH W/SOAP &
WATER. EYES:FLUSH W/WATER FOR AT LEAST 15 MINUTES. CALL MD.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:NIL
Extinguishing Media:WATER.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP EXCESS W/ABSORBENT MATERIAL & FLUSH
REMAINING W/WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CAUTION:MAY CAUSE IRRITATION. AVOID
CONTACT W/SKIN & EYES. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST RECOMMENDED.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:IF CONTACT OCCURS, WASH THOROUGHLY W/WATER. IF
IRRITATION DEVELOPS, CONTACT MD.
Supplemental Safety and Health
PH:8.5-9.8 (AT USE - DILUTION).
================== Physical/Chemical Properties ==================
HCC:B3
Spec Gravity:1.0084 (H2O=1)
pH:SUPDAT
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIGHT YELLOW LIQUID W/NON-DESCRIPT ODOR.
Percent Volatiles by Volume:92
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARD ACCORDING TO LOCAL, STATE & FEDERAL
DISPOSAL PROCEDURES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NAR-HYDE VINYL COLOR SPRAY AEROSOL, 2118
CAGE:IO402
CAGE:IO402
CAGE:42400
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE) (MEK) (SARA III). VP:70
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 35-45%
OSHA PEL:200 PPM;300 STEL
ACGIH TLV:200 PPM;300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETIC ACID, ISOBUTYL ESTER; (ISOBUTYL ACETATE) (SARA
III). VP:12.8
CAS:110-19-0
RTECS #:AI4025000
Fraction by Wt: 15-25%
OSHA PEL:150 PPM
ACGIH TLV:150 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TOLUENE (SARA III). VP:22
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 5-10%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:CYCLOHEXANONE (SARA III). VP:2
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: 0-3%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPANE, 2-METHYL-; (ISOBUTANE (PROPELLANT)). VP:72 PSIA @
100F
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 10-15%
Ingred Name:PROPANE (PROPELLANT). VP:124 PSIA @ 70F.
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 10-15%
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:SUPDAT:TO COMPONENTS OF MATL HAS BEEN SUGGESTED TO CAUSE
LIVER ABNORMALITIES IN HUMANS. OVEREXPOS TO (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:COMPENENTS OF THIS MATL HAS ALSO BEEN FOUND TO CAUSE
THE FOLLOWING EFTS IN LAB ANIMALS:LIVER ABNORMALITIES,(ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:KIDNEY DMG/LUNG DMG, SPLEEN DMG, & BRAIN DMG. MINOR
EMBRYOTOXIC/FETOTOXIC EFTS HAVE BEEN OBSERVED IN LAB (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:RATS EXPOSED TO METHYL ETHYL KETONE BY INHAL AT LEV
GREATER THAN 1000 PPM (5 TIMES OSHA PEL/TWA) FOR (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:MOST OF THE GESTATION PERIOD.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NOTE:TOLUENE (CAS #108-88-3) APPEARS
ON THE NAVY LISTING OF OCCUP REPRO HAZS. SEEK CONSULTATION FROM
APPROP HLTH PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE
HNDLG & EXPOS RECOM . ACUTE: EYES:CONT W/LIQ/VAP MAY RESULT IN
IRRIT, REDNESS, TEARING & BLURRED VISION. SKIN:CONT W/WET MATL MAY
(EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:RESULT IN IRRIT, DERM, & POSS
DEFATTING OF SKIN. INHAL:EXCESS INHAL OF VAP MAY CAUSE NASAL & RESP
IRRIT, ACUTE NERVOUS SYS DEPRESS, FATIGUE, WEAKNESS, NAUS, HDCH,
DIZZ, POSS UNCONSCIOUSNESS & EVEN ASPHY. INGEST:MATL MAY CAUSE GI
IRRIT, NAUS, DIARR & VOMIT. ASPIR OF MATL INTO LUNGS DUE TO VOMIT
MAY (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH IMMED W/LRG AMTS OF WATER FOR AT LEAST 15 MIN.
TAKE TO MD FOR MED TREATMENT. SKIN:IMMED WASH AFFECTED AREA W/SOAP
& WATER. REMOVE CONTAM CLTHG. CONSULT MD IF IRRIT DEV. INHAL:REMOVE
TO FRES H AIR. RESTORE BRTHG. KEEP PERSON WARM & QUIET. TREAT
SYMPTOMATICALLY. GET MD ATTN. INGEST:DRINK 1-2 GLASSES OF WATER TO
DILUTE. KEEP PERSON WARM & QUIET. CONSULT MD/POIS CTL CTR IMMED.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:SUPDAT
Lower Limits:1.1%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . WATER MAY BE USED TO COOL CONTAINERS TO
PREVENT PRESS BUILD UP WHICH MAY RUPTURE CONTAINERS.
Unusual Fire/Explosion Hazard:PROPELLIANT IS LTR THAN AIR & EXTREMELY
FLAMM. SOLV VAPS ARE HVR THAN AIR & MAY TRAVEL ALONG FLOOR & BE
IGNIT AT A DISTANCE FROM WHERE MATL IS BEING (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENT AREA.
WEAR PROTECTIVE EQUIPMENT. AVOID BREATHING VAPORS. CONTAIN SPILL,
ABSORB EXCESS WITH DRY INERT MATERIAL, REMOVE AND DISPOSE OF
PROPERLY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE MATERIAL IN A COOL,
WELL-VENTILATED AREA. DO NOT STORE AT TEMPERATURES ABOVE 120F. DO
NOT USE OR STORE NEAR HEAT, SPARKS OR OPEN FLAME.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. DO NOT TAKE
INTERNALLY. AVOID CONTACT WITH EYES AND SKIN. DO NOT PUNCTURE OR
INCINERATE AEROSOL CONTAINERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATORS DESIGNED TO
REMOVE PARTICULATE MATTER AND ORGANIC SOLVENT VAPORS.
Ventilation:GENERAL DILUTION/LOC EXHAUST VENT SHOULD BE PROVIDED TO
KEEP EXPOS BELOW ACCEPTABLE LIMITS.
Other Protective Equipment:IMPERMEABLE CLOTHING SHOULD BE WORN TO
PREVENT PROLONGED OR REPEATED CONTACT OF WET MATERIAL WITH SKIN.
Work Hygienic Practices:ALWAYS WASH AFTER USING THIS MATERIAL, AND
BEFORE EATING, DRINKING OR SMOKING.
Supplemental Safety and Health
SPEC GRAV:0.793 VD:PAINT:HVR/AIR. PROPELLANT:LTR/AIR. EVAP RATE:ETHYL
ETHER (PROPEL ONLY). % VOLAT:97.92-97.67. FL PT:-156F,104C
(PROPEL), 23F,-5C (PAINT). EXPLOS HAZ:USED. CONTENTS ARE UNDER P
RESS (APPROX 55 +/- 5 PSI AT 70F). EFTSOF OVEREXP:PRODUCE CHEM
PNEUM WHICH MAY BE FATAL. CHRONIC:EXCESS OVEREXP(ING 7)
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:>-44F,>-42C
Vapor Pres:SEE INGS
Vapor Density:SUPDAT
Spec Gravity:0.774-(SUPDAT)
Evaporation Rate & Reference:FASTER THAN (SUPDAT)
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
PEROXIDES; STRONG OXIDIZERS, STRONG MINERAL ACIDS AND STRONG BASES.
Stability Condition to Avoid:HIGH TEMPERATURES AND SOURCES OF IGNITION.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. BEFORE ATTEMPTING CLEAN-UP OR DISPOSING OF
MATERIAL, REFER TO HAZARDOUS INFORMATION IN OTHER SECTIONS OF THIS
MSDS. DO NOT INCINERAT E AEROSOL CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:VBP-300 VISIBLE PENETRANT
CAGE:IO387
CAGE:IO387
CAGE:98733
============= Composition/Information on Ingredients =============
Ingred Name:TERGITOL 15-S-3; (LINEAR ALCOHOL)
CAS:68131-40-8
RTECS #:WZ5200000
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE EYE IRRITATION, MAY CAUSE
MILD SKIN IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:IRRITATION OF EYES/SKIN.
Medical Cond Aggravated by Exposure:PREVIOUS SKIN PROBLEMS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.
CALL PHYSICIAN IF IRRITATION PERSISTS. SKIN: FLUSH WITH COPIOUS
AMOUNTS OF WATER. CALL MD . INHAL: REMOVE TO FRESH AIR. SUPPORT
BRTHG(GI VE O*2/ARTF RESP) . INGEST: CALL MD IMMED .
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>350F,>177C
Extinguishing Media:ALCOHOL FOAM OR WATER FOG OR CO*2 OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPORS ARE HVR/AIR & MAY TRAVEL ALONG
GROUND & BE IGNITED @ A DISTANCE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH VERMICULITE, FLOOR ABSORBENT OR
OTHER ABSORBENT MATERIAL. LIQUID IS BIODEGRADABLE IN SEWER PLANTS @
CONCENTRATIONS LESS THAN 10 PPM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER NORMAL CONDITIONS OF USE. USE
NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN
.
Ventilation:LOCAL EXHAUST/MECH(GEN): TO REDUCE VAPORS.
Other Protective Equipment:CHEMICAL RESISTANT APRON.
Work Hygienic Practices:KEEP OFF SKIN.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>482F,>250C
Melt/Freeze Pt:M.P/F.P Text:77F,25C
Vapor Pres:<0.01
Vapor Density:HVR/AIR
Spec Gravity:1(H*2O=1)
Evaporation Rate & Reference:<0.01(BUTYL ACETATE=1)
Solubility in Water:MISCIBLE
Appearance and Odor:RED SYRUPY LIQUID, MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:CONTACT WITH STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE, AND
LOCAL REGULATIONS. DO NOT DUMP INTO SEWER OR INTO ANY NATURAL BODY
OF WATER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1651 MEDIUM BASE
CAGE:EO559
CAGE:EO559
CAGE:70506
============= Composition/Information on Ingredients =============
Ingred Name:KAOLIN
CAS:1332-58-7
RTECS #:GF1670500
Fraction by Wt: 5-10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9293
Ingred Name:ETHYLENE GLYCOL (SARA III)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: <5%
Other REC Limits:10 MG/CUM
OSHA PEL:C 50 PPM
ACGIH TLV:C 50 PPM,VAPOR; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:3-IODO-2-PROPYNYL BUTYL CARBAMATE
CAS:55406-53-6
RTECS #:EZ0950000
Fraction by Wt: <1%
Ingred Name:WATER, H2O
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 40-60%
Ingred Name:ACRYLIC RESIN
Fraction by Wt: 25%
Other REC Limits:10 MG/CUM (DUST)
Ingred Name:TEXANOL, 1,3-PENTANEDIOL 2,2,4-TRIMETHYL MONOISOBUTYRATE
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: <5%
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 3-20%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:SILICA, AMORPHOUS, DIATOMACEOUS EARTH, CONTAINING LESS THAN
1% CRYSTALLINE SILICA
CAS:61790-53-2
RTECS #:HL8600000
Fraction by Wt: <5%
Other REC Limits:10 MG/CUM
OSHA PEL:20 MPPCF
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF THE
RESPIRATORY TRACT, HEADACHE, NAUSEA, DIZZINESS. SKIN/EYE: PRIMARY
IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: IRRITATION OF THE RESPIRATORY
TRACT, HEADACHE, NAUSEA, DIZZINESS. SKIN/EYE: PRIMARY IRRITATION.
PROLONGED/REPEATED BREATHING OF SPRAY MISTS/SANDING DUST OVER A
PERIOD OF YEARS MAY CAUSE DU ST DISEASE OF THE LUNGS.
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH W/LARGE AMOUNTS
OF WATER FOR AT LEAST 15 MINUTES. CONSULT PHYSICIAN FOR MED
TREATMENT. SKIN: REMOVE W/SOAP & WATER. REMOVE SOILED CLOTHING.
INGESTION: DRIN 1-2 GLASSES OF WATER TO DILUTE. DON'T INDUCE
VOMITING. CONSULT PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:0.62%
Upper Limits:3.2%
Extinguishing Media:CO2, DRY CHEMICAL, FOAM/NATIONAL FIRE PROTECTION
ASSOCIATION NFPA APPROVED METHOD FOR TREATING A CLASS B FIRE.
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIPMENT INCLUDING SCBA.
WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE.
Unusual Fire/Explosion Hazard:WATER SHOULD BE USED TO COOL CLOSED
CONTAINERS/PREVENT PRESSURE BUILD-UP/POSSIBLE AUTO-IGNITION/HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:WASH W/WATER. CONTAIN SPILLED MATERIAL &
REMOVE W/INERT ABSORBENT. STORE IN CLOSED CONTAINER UNTIL PROPERLY
DISPOSED OF.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T BREATHE VAPORS, SPRAY
MIST/SANDING DUST. DON'T GET IN EYES. STORE <110F & KEEP FROM
FREEZING. KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:DON'T REUSE EMPTY CONTAINERS. KEEP OUT OF REACH OF
CHILDREN. USE NIOSH/MSHA APPROVED RESPIRATORS WHEN FLAME CUTTING,
WELDING, BRAZING & SANDING MATERIAL COATED WITH THIS PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN AREAS W/UNRESTRICTED VENTILATION & DURING
SANDING/GRINDING OPERATIONS, USE NIOSH/MSHA APPROVED MECHANICAL
FILTER RESPIRATOR TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY &
SANDING DUST. WEAR NIOS H/MSHA APPROVED AIR SUPPLY/HOODS.
Ventilation:PROVIDE ADEQUATE MECHANICAL/LOCAL EXHAUST VENTILATION TO
KEEP <TLV.
Work Hygienic Practices:REMOVE/WASH SOILED CLOTHING BEFORE REUSE. WASH
HANDS BEFORE EATING, SMOKING/USING THE WASHROOM.
Supplemental Safety and Health
WT PER GAL: 9.32-10.82 LBS
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212-490F
Vapor Density:<AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:69.7%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, FLAME
Hazardous Decomposition Products:CO, CO2, OXIDES OF NITROGEN & METALS.
MAY CAUSE HAZARDOUS FUMES WHEN HEATED TO DECOMPOSITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS. INCINERATE ONLY IN APPROVED FACILITY. DON'T
INCINERATE CLOSED CONTAINERS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:ALPHA NAPHTHOL
CAGE:55194
CAGE:55194
============= Composition/Information on Ingredients =============
Ingred Name:1-NAPHTHOL
CAS:90-15-3
RTECS #:QL2800000
Fraction by Wt: 100%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:LARGE INGESTION CAUSES NEPHRITIS,
VOMITING, DIARRHEA, CIRCULATORY COLLAPSE, ANEMIA, CONVULSIONS AND
DEATH. ABSORPTION THROUGH SKIN MAY CAUSE IRRITATION TO KIDNEYS AND
INJURY TO THE CORNEA AND LENS OF EYE.
Explanation of Carcinogenicity:NOT LISTED.
Effects of Overexposure:LARGE INGESTION CAUSES NEPHRITIS, VOMITING,
DIARRHEA, CIRCULATORY COLLAPSE, ANEMIA, CONVULSIONS AND DEATH.
ABSORPTION THROUGH SKIN MAY CAUSE IRRITATION TO KIDNEYS AND INJURY
TO THE CORNEA AND LENS OF EYE.
Medical Cond Aggravated by Exposure:KIDNEY DISORDERS.
======================= First Aid Measures =======================
First Aid:SKIN: WASH THOROUGHLY WITH SOAP & WATER; CALL A PHYSICIAN.
EYES: FLUSH WITH WATER FOR 15 MINUTES; CALL A PHYSICIAN.
INHALATION: REMOVE TO FRESH AIR; CALL A PHYSICIAN. INGESTION: CALL
A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:310F,154.4C
Lower Limits:0.8 (EST.)
Upper Limits:5.0 (EST.)
Extinguishing Media:CARBON DIOXIDE (CO2), CRY CHEMICAL, FOAM
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS. WEAR
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:AVOID DUSTING TO REDUCE POTENTIAL
EXPLOSIVE HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:COLLECT WITH A BRUSH ON TO A PAPER SHEET.
PLACE IN AN IRON PAN IN HOOD. BURN THE PAPER.
Neutralizing Agent:NONE SPECIFIED.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN DARK PLACE.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED MULTI PURPOSE GAS MASK.
Ventilation:LOCAL EXHAUST HOOD
Other Protective Equipment:COVERALLS TO MINIMIZE SKIN CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER USE.
Supplemental Safety and Health
TOXIC IRRITANT.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:541F,283C
Melt/Freeze Pt:M.P/F.P Text:204F,96C
Vapor Pres:<1
Vapor Density:5
Spec Gravity:1.224
Solubility in Water:SLIGHT
Appearance and Odor:OFF WHITE TO PINK CRYSTALLINE POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CARBON DIOXIDE; CARBON MONOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MULTIGRADE RP FIXER,PART B
Kit Part:Y
CAGE:64145
CAGE:64145
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 1-3%
Other REC Limits:NOT SPECIFIED
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:1-PHENYL-1H-TETRAZOLA-5-THIOL,
(1-PHENYL-5-MERCAPTOTETRAZOLE)
CAS:86-93-1
RTECS #:XF7700000
Fraction by Wt: 4-6%
Other REC Limits:NONE SPECIFIED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 90-95%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT MAY CAUSE EYE, SKIN AND G/I
TRACT IRRITATION. IT IS CONSIDERED A LOW HAZARD FOR NORMAL
INDUSTRIAL HANDLING.
Explanation of Carcinogenicity:THIS PRODUCT CONTAINS NO INGREDIENT
LISTED AS CARCINOGEN BY IARC,NTP, OR OSHA.
Effects of Overexposure:EYE: CAUSES IRRITATION. SKIN: CAUSES
IRRITATION. INHALATION: MAY CAUSE IRRITATION IF DUST OR MIST IS
INHALED. INGESTION: MAY BE HARMFUL IF SWALLOWED. MAY CAUSE G/I
TRACT IRRITATION, NAUSEA, VOMITING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. IF IRRITATION
PERSISTS GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH AREA WITH SOAP AND WATER. IF IRRITATION PERSISTS GET MEDICAL
ATTENTION.INHALATION: MOVE TO FRESH AIR. RESTORE BREATHING IF
NECESSARY. GET MEDICAL ATTENTION IF NEEDED. INGESTION: GIVE 3-4
GLASSES OF WATER. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:USE MEDIA APPROPRIATE FOR SOURCE OF FIRE.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA
AND FULL PROTECTIVE EQUIPMENT TO PREVENT CONTACT WITH SKIN AND
EYES.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:NEUTRALIZE AND FLUSH TO DRAIN OR RECOVER
LIQUID THEN NEUTRALIZE.
Neutralizing Agent:ACETIC ACID FOLLOWED BY SODIUM BICARBONATE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP TIGHTLY CLOSED WHEN NOT IN USE. KEEP AWAY FROM ACIDS.
Other Precautions:READ LABEL THEN FOLLOW INSTRUCTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. USE NIOSH/MSHA APPROVED
RESPIRATOR IF PEL/TLV IS EXCEEDED OR IF LOCAL EXHAUST IS
UNAVAILABLE DURING MIXING.
Ventilation:NORMAL ROOM VENTILATION IS SUFFICIENT. SUPPLEMENT WITH
LOCAL EXHAUST WHEN DOING INITIAL MIXING.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER. USE
APRON AND FACE SHIELD WHEN MIXING LIQUIDS OR IF SPLASHING IS
LIKELY.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
KEY 1: C4, THIS ENTRY DESCRIBES PART B OF A TWO PART KIT. SEE PN IND A,
THIS NSN, FOR PART A DATA. ILFORD STOCK NUMBER MG9112312 (5 GALLON)
TO MAKE 20 GALLON.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:>212F,>100C
Spec Gravity:1.020
pH:12
Evaporation Rate & Reference:SAME AS WATER
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR COLORLESS SOLUTION. SLIGHT ODOR.
Percent Volatiles by Volume:93 WT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MINERAL ACIDS.
Stability Condition to Avoid:NO INFORMATION GIVEN BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
SULFUR OXIDES, AMMONIA.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS. MANUFACTURER SUGGESTS FLUSHING WASTE TO
SEWER IF PERMITTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:XV-931 INHIBITOR
CAGE:TO614
CAGE:TO614
============= Composition/Information on Ingredients =============
Ingred Name:DIALLYL PHTHALATE
CAS:131-17-9
RTECS #:CZ4200000
Minumum % Wt:92.
Maxumum % Wt:98.
Ingred Name:BENZOQUINONE
CAS:106-51-4
RTECS #:DK2625000
Minumum % Wt:2.
Maxumum % Wt:8.
OSHA PEL:0.4 MG/M3;0.1 PPM
ACGIH TLV:0.44 MG/M3;0.1 PPM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE GIVEN FOR PRODUCT AS WHOLE
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:POTENTIAL CANCER HAZARD. EYE BURNS.
SKIN BURNS. HARMFUL IF SWALLOWED. LUNG IRRITANT. HAS TESTED
POSITIVE AS MUTAGEN. MAY AFFECT LIVER. MAY EFFECT THE CIRCULATORY
SYSTEM. MAY INFLUENCE, OR CAUSE, TUMOR (S) GROWTH. MAY CAUSE
NERVOUS SYSTEM EFFECTS. MAY CAUSE BLOOD CHEMISTRY CHANGES. MAY
AFFECT MUCOUS MEMBRANES. MAY CAUSE GASTROINTESTINAL DISTURBANCES.
Explanation of Carcinogenicity:BENZOQUINONE, CAS# 196-51-4, IARC-GROUP
3 (NOT CLASSIFIABLE), MONOGRAPH 15, SUPPLEMENT 7; 1987.
Effects of Overexposure:SKIN: RASH, IRRITATION. EYE: IRRITATION.
INHALATION: IRRITATION - RESPIRATORY TRACT. INGESTION: GASTRITIS.
CARDIOVASCULAR: TACHYCARDIA, ARRHYTHMIA.
Medical Cond Aggravated by Exposure:NO DATA PROVIDED BY RESPONSIBLE
PARTY
======================= First Aid Measures =======================
First Aid:SKIN: IMMEDIATELY REMOVE CONTAMINATED CLOTHING. FLUSH WITH
LARGE AMOUNTS OF WATER. IF ANY ADVERSE EFFECTS PERSIST, GET MEDICAL
ATTENTION. EYE: RINSE IMMEDIATELY WITH PLENTY OF WATER & SEEK
MEDICAL ADV ICE. INHALATION: MOVE PERSON TO NON-CONTAMINATED AIR.
IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS
DIFFICULT, GIVE OXYGEN. SEEK MEDICAL ATTENTION. INGESTION: IF THE
MATERIAL IS SWALL OWED, GET IMMEDIATE MEDICAL ATTENTION OR ADVICE.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS OR CONVULSING
VICTIM. NOTES TO PHYSICIAN: PROVIDE GENERAL SUPPORTIVE MEASURES &
TREAT SYMPTOMATICALLY. A SPECIFIC ANTIDOTE IS NOT KNOWN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:=165.C, 329.F
Extinguishing Media:DRY CHEMICAL, FOAM, CARBON DIOXIDE, WATER FOG
Fire Fighting Procedures:EXCLUDE AIR, TREAT LIKE A GASOLINE OR OIL
FIRE. WEAR FULL PROTECTIVE CLOTHING, INCLUDING HELMET,
SELF-CONTAINED POSITIVE PRESSURE OR PRESSURE DEMAND BREATHING
APPARATUS, PROTECTIVE CLOTHING & FACE MAS K.
Unusual Fire/Explosion Hazard:NONE PROVIDED BY MFR.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR APPROPRIATE PROTECTIVE EQUIPMENT &
CLOTHING DURING CLEAN-UP. ELIMINATE IGNITION SOURCES. VENTILATE THE
CONTAMINATED AREA. SWEEP UP MATERIAL & PLACE IN AN APPROPRIATE
CONTAINER FOR TRANSPORT OR DI SPOSAL. THOROUGHLY CLEAN RELEASE AREA
WITH SUITABLE AGENT & COLLECT ANY CLEANING MEDIA FOR DISPOSAL.
VENTILATE AREA. CONTAIN SPILL, KEEP OUT OF WATERWAYS & CONFINED
SPACES
Neutralizing Agent:NO DATA PROVIDED BY RESPONSIBLE PARTY
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MAINTAIN MATERIAL'S VAPORS, FUMES, OR
PARTICULATE AMBIENT LEVELS BELOW ANY LEVELS OF CONCERN INCLUDING AS
A NUISANCE DUST (10 MG/M3). RESPIRATORS SHOULD BE SELECTED BY &
USED UNDER THE DIRECTION OF A TRAINED HEALTH & SAFETY PROFESSIONAL
FOLLOWING THE REQUIREMENTS FOUND IN OSHA'S RESPIRATOR STAND (29 CFR
1910.134). OR ANSI Z-88.1-1992.
Ventilation:VENTILATION SHOULD BE SUFFICIENT TO EFFETIVELY REMOVE &
PREVENT BUILDUP OF ANY DUSTS OR FUMES THAT MAY BE GENERATED DURING
HANDLING OR THERMAL PROCESSING
Other Protective Equipment:NO DATA PROVIDED BY RESPONSIBLE PARTY
Work Hygienic Practices:USE GOOD INDUSTRIAL HYGIENE PRACTICES IN
HANDLING THIS MATERIAL
Supplemental Safety and Health
CANADA: WHIMIS CLASSIFICATIONS: E, D1A, D2B.
================== Physical/Chemical Properties ==================
HCC:V7
Vapor Density:> AIR
Spec Gravity:1.09 TO 1.11
Evaporation Rate & Reference:< ETHER
Solubility in Water:NOT VERY SOLUBLE (<1%)
Appearance and Odor:NEARLY COLORLESS, OILY LIQUID WITH A MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:STABLE UNDER NORMAL CONDITIONS. KEEP AWAY
FROM HEAT, SPARKS, OR OPEN FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
AND/OR LOW MOLECULAR WEIGHT HYDROCARBONS.
Conditions to Avoid Polymerization:WILL NOT OCCUR UNDER NORMAL
CONDITIONS.
=================== Toxicological Information===================
Toxicological Information:ORGANS EFFECTED: LIVER, BLOOD, HEART. ACUTE
SKIN CONTACT-DERMAL LD50: DIALLYL PHTHALATE, CAS# 131-17-9, DERMAL
LD50 (RABBIT): 3400 MG/KG. ACUTE INGESTION- ORAL LD50: DIALLYL
PHTHALATE, CAS# 131-17-9, ORAL LD50 (RAT): 655 MG/KG.
BENZOQUINONE, CAS# 106-5-4, ORAL LD50 (RAT): 130 MG/KG. ACUTE
INHALATION-INHALATION LC50'S: DIALLYL PHTHALATE, CAS# 131-17-9,
INHALATION LC50 (RAT): 5200 MG/M3/1 HR. CHRONI C HEALTH HAZARDS:
BENZOQUINONE, CAS# 196-51-4, IARC-GROUP 3 (NOT CLASSIFIABLE),
MONOGRAPH 15, SUPPLEMENT 7; 1987.
===================== Ecological Information =====================
Ecological:ECOTOXICITY: DIALLYL PHTHALATE: AQUATIC TOXICITY MAY
BIOCONCENTRATE (BCF=168). BENZOQUINONE: AQUATIC TOXICITY: PERCH
LD50 = 5-10 MG/L; LOW BIOCONCENTRATION. ENVIRONMENTAL FATE: DIALLYL
PHTHALATE: ARTI FICIAL SOURCES: EMISSIONS & WASTE FROM ITS USE AS A
CHEMICAL INTERMEDIATE & PLASTICIZER. TERRESTRIAL FATE: LOW
MOBILITY, LOW VOLITILIZATION, BIODEGRADES. AQUATIC FATE: ADSORBS TO
SEDIMENTS, MINIMAL VO LITILIZATION, BIODEGRADES (BOD14~80%);
HYDROLYZES (HALF-LIFE~37 DAYS @ PH 8). ATMOSPHERIC FATE:
PHOTOCHEMICALLY DEGRADES (HALF-LIFE ~ 7 HOURS). BENZOQUINONE: SEE
OTHER.
==================== Disposal Considerations ====================
Waste Disposal Methods:ALL WASTES MUST BE HANDLED IN ACCORDANCE WITH
LOCAL, STATE, AND FEDERAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:US DOT DOMESTIC OVERLAND: IF PACKED IN DRUMS OR
BAGS: ENVIRONMENTALLY HAZARDOUS SUBSTANCES, LIQUID, N.O.S.
(P-BENZOQUINONE). CLASS: 9. IDENTIFICATION NUMBER: UN3082. PACKING
GROUP III. IF PACKED IN PA ILS OR CANS: RESIN, COAL TAR OR
PETROLEUM, NON-DANGEROUS GOODS.
===================== Regulatory Information =====================
SARA Title III Information:SARA SECTION 313 EMISSION REPORTING:
BENZOQUINONE, CAS# 106-5-4, FORM R REPORTING REQUIRED FOR 1% DE
MINIMUS CONCENTRATION. SARA 312 HEALTH HAZARDS: ACUTE, CHRONIC
Federal Regulatory Information:CAA: 1990 HAZARDOUS AIR POLLUTANTS
(HAP'S)/HON RULE-ORGANIC HAP'S/HON RULE-SOCMI CHEMICALS:
BENZOQUINONE, CAS# 106-51-4 (SOCMI COMPLIANCE BY APRIL 214, 1995).
THIS MATERIAL IS ON THE TSCA INVENTORY LI ST.
State Regulatory Information:BENZOQUINONE, CAS # 106-51-4 LISTED IN
FOLLOWING STATE LISTS: CALIFORNIA (8 CCR 339), FLORIDA HAZARDOUS
SUBSTANCE LIST, MASSACHUSETTS RIGHT TO KNOW LIST, MINNESOTA
HAZARDOUS SUBSTANCE LIST, NJ RTK, NJ ENVIRONMENTAL HAZARDOUS
SUBSTANCE LIST, PENNSYLVANIA RTK, RHODE ISLAND HAZARDOUS SUBSTANCE
LIST. DIALLYLY PHTHALATE IS LISTED ON THE FOLLOWING STATE LISTS:
FLORIDA HAZARDOUS SUBSTANCE LIST, MASSACHUS ETTS RTK, PENNSYLVANIA
RTK. RTK=RIGHT-TO-KNOW.
======================= Other Information =======================
| 1 | gloves_mandatory |
=======================================================
Product ID: TECTYL 966, 50010966
Cage: GO029
Box: 14000
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: GO029
Box: 14000
Cage: 72527
Box: 14000
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: EYES: CAN CAUSE MODERATE IRRITATION, REDNESS,
TEARING. SKIN: CAN CAUSE SLIGHT IRRITATION. INGEST: CAN CAUSE
GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING, AND DIARRHEA. INHAL:
INHALATION OF MIS T CAN CAUSE IRRITATION OF NASAL AND RESPIRATORY PASSAGES.
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: SKIN: THORO WASH EXPOSED AREA W/SOAP & WATER. REMOVE CONTAM
CLTHG & LAUNDER BEFORE REUSE. EYES: FLUSH W/LGE AMTS OF WATER FOR AT
LEAST 15 MIN, LIFTING UPPER & LOWER LIDS OCCASNLY. GET MD ATTN. INGEST:
DO NOT INDUCE VOMIT, KEEP PERS WARM & QUIET, & GET MD ATTN. INHAL:
REMOVE PERS TO FRESH AIR. IF BRTHG DFCLT, ADMINISTER O*2. IF BRTHG HAS
STOPPED GIVE ARTF RESP. KEEP PERS WARM, QUIET & GET MD ATTN.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SML SPILL: ABSORB LIQ ON PAPER, VERMICULITE, FLOOR
ABSORB/OTHER ABSORB MATL. LGE SPILL: ELIMINATE ALL IGNIT SOURCES (FLARES,
FLAMES INCL PILOT LIGHTS, ELEC SPARKS). PERS NOT WEARING PROT EQUIP SHOULD
BE EXCLUDED FROM AREA OF SPILL UNTIL (SUP DAT)
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE, AND
FEDERAL REGULATIONS.
Handling And Storage Precautions: CONTRS OF MATL MAY BE HAZ WHEN EMPTIED. SINCE
EMPTIED CONTRS RETAIN PROD RESIDUES (VAP, LIQ, &/SOLID), ALL HAZ PREC
GIVEN IN MSDS MUST BE OBSERVED.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: 420F,216C
Extinguishing Media: REGULAR FOAM, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPRVD SCBA OPERATED IN POS PRESS
DEMAND & FULL PROT EQUIP. WATER/FOAM MAY CAUSE FROTHING WHICH CAN BE
VIOLENT & POSS ENDANGER LIFE (SUP DAT)
Unusual Fire/Explosion Hazard: NEVER USE WELDING/CUTTING TORCH ON/NEAR DRUM
(EVEN EMPTY) BECAUSE PRODUCT (EVEN JUST RESIDUE) CAN IGNITE EXPLOSIVELY.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH/MSHA APPRVD RESP APPROP FOR EXPOS OF CONCERN.
OSHA REGS ALSO PERMIT OTHER NIOSH/MSHA RESP (NEG PRESS TYPE) UNDER SPECIFIED
CNDTNS (SEE YOUR SFTY EQUIP SUPPLIER). ENGINEERING/ADMIN CTLS SHOUL D BE
IMPLEMENTED TO REDUCE EXPOS.
Ventilation: PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment: TO PREVENT REPEATED OR PROLONGED SKIN CONTACT, WEAR
IMPERVIOUS CLOTHING AND BOOTS.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: USERS OF THE "L" VERSION SHOULD CONSULT THE
"LR" VERSION FOR FURTHER INFO (FP N). FIRE FIGHT PROC: OF FIREFIGHTER,
ESPECIALLY IF SPRAYED INTO CONTRS OF HOT, BURNING LIQ. SPILL PROC: CLEAN-UP
HAS BEEN COMPLETED. STOP SPILL AT SOURCE, DIKE AREA OF SPILL TO PREVENT
SPREADING, PUMP LIQ TO SALVAGE TANK. REMAINING
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >425F,>218C
Vapor Density: HVR/AIR
Spec Gravity: 0.890-0.900
Evaporation Rate & Reference: SLOWER THAN ETHER
Appearance and Odor: LIQUID
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: NONE SPECIFIED BY MANUFACTURER.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: TECTYL 966, 50010966
Cage: GO029
Assigned IND: Y
Company Name: VALVOLINE INC
PO Box: 14000
Zipcode: 40512
Label Required IND: Y
Date Of Label Review: 04/14/1995
Status Code: C
Label Date: 04/14/1995
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE: EYES: CAN CAUSE MODERATE
IRRITATION, REDNESS, TEARING. SKIN: CAN CAUSE SLIGHT IRRITATION. INGEST: CAN
CAUSE GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING, AND DIARRHEA. INHAL:
INHA LATION OF MIST CAN CAUSE IRRITATION OF NASAL AND RESPIRATORY PASSAGES.
CHRONIC: NONE SPECIFIED BY MANUFACTURER.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-H-83282C HYD FLUID,A 3000
Preparer's Name:RICHARD J. EBERHARDT
CAGE:8Y842
CAGE:8Y842
CAGE:1DL10
============= Composition/Information on Ingredients =============
Ingred Name:POLYALPHAOLEFIN BASE STOCK/SYNTHETIC HYDROCARBON BASE
CAS:68649-12-7
Fraction by Wt: <65%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 AS OIL MIST
ACGIH TLV:5 MG/M3 AS OIL MIST
Ingred Name:ADIPIC ACID, DIISODECYL ESTER
CAS:27178-16-1
RTECS #:AV1485000
Fraction by Wt: <35%
Other REC Limits:NONE RECOMMENDED
Ingred Name:LUBRICANT ESTER BASE
CAS:110-29-2
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV = 5 MG/M3 AS OIL MIST
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY
TRACT. ACUTE- EYES/SKIN/ORAL:NOT NORMALLY EXPECTED TO CAUSE ANY ILL
EFFECTS EXCEPT IN VERY SENSITIVE INDIVIDUALS. INHALE:NO SIGNIFICANT
ADVERSE HEALTH EFFECTS AREEXPECTED TO OCCUR ON SHORT TERM
EXPOSURE. CHRONIC- MAY CAUSE MILD SKIN IRRITATION & INFLAMMATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, NAUSEA, INFLAMMATION
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15
MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP & WATER. ORAL:DO
NOT IN DUCE VOMITING. IF CONSCIOUS, RINSE MOUTH WITH WATER. SEEK
MEDICAL ATTENTION. IF SPONTANEOUS VOMITING OCCURS, KEEP HEAD BELOW
HIPS.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>392F,>200C
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL/CARBON DIOXIDE. DON'T
USE DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE
REIGNITED.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED OR CONFINED AREA
WITHOUT PROPER PROTECTIVE EQUIPMENT AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:SLIGHTLY COMBUSTIBLE. WHEN HEATED ABOVE
FLASH POINT, WILL RELEASE FLAMMABLE VAPORS WHICH CAN BURN IN OPEN
OR BE EXPLOSIVE IN CONFIED SPACES. CAN MAY BURST.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. SPILLS CAN BE TAKEN
UP ON SAND, CLAY, EARTH & SHOVELD INTO CONTAINERS. PREVENT RUN-OFF
TO ENTER WATERWAYS, SEWERS.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, VENTILATED PLACE
AWAY FROM STRONG OXIDIZERS. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:AVOID CONTACT WITH EYES AND SKIN. WASH THOROUGHLY
AFTER HANDLING. LAUNDER CLOTHING BEFORE REUSE. AVOID INHALING
MISTS. EMPTY CONTAINERS OF THIS PRODUCT MAY BE HAZARDOUS DUE TO THE
RETENTION OF RESIDUE S. DO NOT TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. IF WORKING IN CONFINED
AREAS, IF EXCESSIVE MISTING IS EXPECTED OR IF EXPOSURE MAY OR DOES
EXCEED RECOMMENDED PERMISSIBLE EXPOSURE LIMITS (PEL), WEAR
NIOSH-APPROVED ORGANIC VAPO R RESPIRATOR.
Ventilation:GENERAL ROOM VENTILATION SHOULD BE SUFFICIENT.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
SHOES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V6
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:>599F,>315C
Vapor Pres:<0.01 @68F
Vapor Density:>1
Spec Gravity:0.853
Solubility in Water:NEGLIGIBLE
Appearance and Odor:RED, OILY LIQUID - PETROLEUM ODOR
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT (HEATING ABOVE FLASH POINT)
Hazardous Decomposition Products:CARBON MONOXIDE AND ASPHYXIANTS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN AN APPROPRIATE DISPOSAL FACILITY
IN COMPLIANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AROCLOR 1262, 44810
CAGE:54968
CAGE:54968
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYL; (AROCLOR 1262) LD50: (ORAL, RAT)
11200 MG/KG
CAS:37324-23-5
RTECS #:TQ1364000
Fraction by Wt: 0.1%
OSHA PEL:0.5 MG/M3 (MFR)
ACGIH TLV:0.5 MG/M3 (MFR)
Ingred Name:PENTANE, 2,2,4-TRIMETHYL-(CERCLA)
CAS:540-81-1
RTECS #:SA3320000
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE & CHRONIC: CONTAINS MATERIAL(S)
KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN:FLUSH
WITH LARGE VOLUME OF WATER. INHALATION:IMMEDIATELY MOVE TO FRESH
AIR. GIVE OXYGEN IF BREATHING IS LABORED IF BREATHING STOPS, GIVE
ARTIFICIALRESPIRATION. INGESTION:NEVER GIVE ANYTHING BY MOUTH TO
AN UNCONSCIOUS PERSON NEVER TRY TO MAKE AN UNCONSCIONS PERSON VOMIT
DO NOT INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:10F,-12C
Lower Limits:1.1%
Upper Limits:6.0%
Extinguishing Media:CO*2, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CAN REACT VIGOROUSLY WITH REDUCING
MATERIALS.
================== Accidental Release Measures ==================
Spill Release Procedures:TAKE UP WITH ABSORBENT MATERIAL VENTILATE
AREA.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN SEALED CONTAINER IN COOL, DRY
LOCATION. KEEP AWAY FROM HEAT. STORE IN DRY, WELL VENTILATED AREA.
KEEP AWAY FROM IGNITION SOURCES.
Other Precautions:AVOID EYE OR SKIN CONTACT. AVOID BREATHING VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . WEAR FACE MASK WITH ORGANIC VAPOR CANISTER.
Ventilation:USE ONLY IN WELL VENTILATED AREA.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:210F,99C
Melt/Freeze Pt:M.P/F.P Text:-177F,-116C
Vapor Pres:41
Vapor Density:3.90
Spec Gravity:.690 (H*2O = 1)
Evaporation Rate & Reference:>1 (ETHER = 1)
Appearance and Odor:CLEAR COLORLESS LIQUID.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REDUCING AGENTS.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:NOT APPLICABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY WITH ALL APPLICABLE FEDERAL, STATE, OR
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TT-P-1952C TY 2 35180 BLUE 700L45
Preparer's Name:ROBERT COMMISSO
CAGE:DO312
CAGE:58963
CAGE:DO312
============= Composition/Information on Ingredients =============
Ingred Name:ACRYLIC POLYMER PLUS PROPRIETARY ADDITIVES
Fraction by Wt: 30%
Other REC Limits:NONE RECOMMENDED
Ingred Name:MAGNESIUM SILICATE
CAS:14807-96-6
RTECS #:MW2700000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:2 MG/M3
Ingred Name:METHANOL (VAPOR PRESSURE 5.9 MM HG @ 68F) (SARA 313)
(CERCLA)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:MATERIAL VOC: 0.65 LB/GL (78 G/L)
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: ADVERSE HEALTH EFFECTS
FROM VAPOR/SPRAY MIST IN POORLY VENTED AREAS MAY INCLUDE IRRITATION
OF NOSE, THROAT, RESPIRATORY TRACT. HEADACHE & NAUSEA MAY ALSO
OCCUR. SKIN: PROLONGED/REPEATED CO NTACT MAY CAUSE IRRITATION. EYE:
DIRECTCONTACT MAY RESULT IN IRRITATION. INGESTION: IRRITATION &
MUCOUS MEMBRANE DAMAGE
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR AND GIVE ARTIFICIAL
RESPIRATION OR OXYGEN IF NEEDED. CALL A PHYSICIAN. INGESTION: DO
NOT INDUCE VOMITING. CALL A PHYSICIAN. EYE: FLUSH EYES WITH WATER
FOR 15 MINUTES. C ALL A PHYSICIAN. SKIN CONTACT: WASH SKIN WITH
SOAP AND WATER. CALL A PHYSICIAN IF IRRITATION PERSISTS.
===================== Fire Fighting Measures =====================
Lower Limits:7.3
Extinguishing Media:NONE KNOWN * 9.5
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:PRODUCT WILL NOT BURN BUT MAY SPATTER IF
TEMPERATURE EXCEEDS BOILING POINT. POLYMER FILMS ARE CAPABLE OF
BURNING GIVING OFF OXIDES OF CARBON/NITROGEN.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. DIKE AND
CONTAIN SPILL WITH INERT MATERIAL. TRANSFER LIQUID TO CONTAINERS.
KEEP SPILLS AND RUNOFFS OUT OF MUNICIPAL SEWERS AND OPEN BODIES OF
WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID FREEZING. AVOID CONTACT WITH
MICROORGANISMS. KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:CAUTION - MAY BE HARMFUL IF SWALLOWED. BREATHING
VAPOR OR MIST MAY BE HARMFUL. USE WITH ADEQUATE VENTILATION. AVOID
EYE AND SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURE EXCEEDS PERMISSIBLE EXPOSURE LIMITS,
USE APPROPRIATE NIOSH APPROVED RESPIRATORY EQUIPMENT.
Ventilation:LOCAL EXHAUST RECOMMENDED. MECHANICAL VENTILATION
RECOMMENDED.
Other Protective Equipment:EYE WASH FOUNTAIN, SAFETY SHOWER
Work Hygienic Practices:WASH HANDS BEFORE EATING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:147 TO 212F
Vapor Density:> AIR
Spec Gravity:1.6 (H2O=1)
pH:9.2- *
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:100%
Appearance and Odor:VISCOUS LIQUID WITH SLIGHT AMMONIA ODOR
Percent Volatiles by Volume:41.5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:FREEZING TEMPERATURES
Hazardous Decomposition Products:NONE KNOWN
Conditions to Avoid Polymerization:FREEZING TEMPERATURES
==================== Disposal Considerations ====================
Waste Disposal Methods:OBEY RELEVANT LOCAL, STATE, AND FEDERAL LAWS. DO
NOT CONTAMINATE ANY LAKES, PONDS, STREAMS, OR UNDERGROUND WATER
SUPPLIES. TREAT AS HAZARDOUS WASTE. DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE, AND L OCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ETERNACELL
Preparer's Name:R ZEZULA
CAGE:5G978
CAGE:5G978
Contract Num:SP0430-00-M-KK63
CAGE:0LEJ1
============= Composition/Information on Ingredients =============
Ingred Name:MANGANESE DIOXIDE
CAS:1313-13-9
RTECS #:OP0350000
Minumum % Wt:36.
Maxumum % Wt:42.
OSHA PEL:C5 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:LITHIUM METAL
CAS:7439-93-2
RTECS #:OJ5540000
Minumum % Wt:2.
Maxumum % Wt:4.
Ingred Name:PROPYLENE CARBONATE
CAS:108-32-7
RTECS #:FF9650000
Minumum % Wt:4.
Maxumum % Wt:6.
Ingred Name:1,2-DIMETHOXYETHANE
CAS:110-71-4
RTECS #:KI1451000
Minumum % Wt:6.
Maxumum % Wt:8.
Ingred Name:1,3-DIOXOLAN
CAS:646-06-0
RTECS #:JH6760000
Minumum % Wt:3.
Maxumum % Wt:5.
Ingred Name:LITHIUM SALTS
Minumum % Wt:2.
Maxumum % Wt:3.
Ingred Name:STEEL CASING & NON-HAZARDOUS INGREDIENTS
Minumum % Wt:34.
Maxumum % Wt:47.
===================== Hazards Identification =====================
LD50 LC50 Mixture:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:RISK OCCURS IF CELL VENTS OR IS
OPENED. ELECTROLYTE IS MILD IRRITANT. INTACT LITHIUM IS REACTIVE.
AVOID CONTACT. CHRONIC: MAY CAUSE DERMATITUS. SOME COMPONENTS
HAVE BEEN SHOWN TO BE TERATOGINIC TO ANIMALS. AVOID CONTACT.
Explanation of Carcinogenicity:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Effects of Overexposure:EXPOSURE TO SKIN OR EYES MAY CAUSE IRRITATION.
INHALATION MAY RESULT IN DIFFICULTY BREATHING.
Medical Cond Aggravated by Exposure:UNKNOWN.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES SEEK MEDICAL
ASSISTANCE. SKIN: FLUSH WITH WATER FOR 15 MINUTES. SEEK MEDICAL
ASSISTANCE. INHALATION: REMOVE TO FRESH AIR. SEEK MEDICAL
ASSISTANCE.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY SAND, LITH-X, METAL-X.
Fire Fighting Procedures:COOL BATTERY WITH EXTINGUISHING MEDIA, REMOVE
ADJACENT COMBUSTIBLE MATERIALS IF SAFE TO DO SO, SCBA REQUIRED.
Unusual Fire/Explosion Hazard:CELLS CAN VENT ELECTROLYTE IF SUBJECTED
TO TEMPERATURES OF160F OR GREATER. HEATING ABOVE 354F WILL LEAD TO
MELTING OF LITHIUM AND REPRESENTS A SEVERE FIRE AND EXPLOSION
HAZARD. ELECTROLYTE IS FLAMMABL E.
================== Accidental Release Measures ==================
Spill Release Procedures:ALLOWBATTERY TO COOL AND VAPOR TO DISSIPATE.
AVOID CONTACT. AVOID INHALATION OF VAPORS. REMOVE SPILLED
ELECTROLYTE WITH ABSORBANT MATERIAL. WEAR FULL FACE ORGANIC
CARTRIDGE RESPIRATOR.
Neutralizing Agent:NO DATA PROVIDED BY RESPONSIBLE PARTY.
======================Handling and Storage ======================
Handling and Storage Precautions:BATTERIES MAY EXPLODE, IGNITE, OR VENT
ELECTROLYTE IF CRUSHED, OPENED, PUNCTURED, OR EXPOSED TO
TEMPERATURES IN EXCESS OF 160F. DO NOT SHOUR CIRCUIT, INSTALL WITH
INCORRECT POLARITY, OR ATTEMPT TO RE CHANGE. DO NOT INCENERATE.
Other Precautions:NO DATA PROVIDED BY RESPONSIBLE PARTY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE FULL FACE ORGANIC VAPOR RESPIRATOR IF CELL
VENTS.
Ventilation:PROVIDE IF CELL VENTS.
Other Protective Equipment:USE ENCAPSULATING SUIT IF FIRE OCCURS.
Work Hygienic Practices:AVOID EXPOSURE. WASH HANDS AFTER HANDLING.
Supplemental Safety and Health
NO DATA PROVIDED BY RESPONSIBLE PARTY.
================== Physical/Chemical Properties ==================
HCC:Z6
Solubility in Water:DO NOT EXPOSE TO WATER.
Appearance and Odor:APPEARANCE OF SMALL BATTERY; CYLINDRICAL OR
BOXLIKE. NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
DO NOT EXPOSE TO WATER.
Stability Condition to Avoid:DO NOT HEAT ABOVE 160F, PUNCTURE, OPEN
CELL, SHORT CIRCUIT, OR ATTEMPT TO RECHARGE.
Hazardous Decomposition Products:MAY INCLUDE CARBON MONOXIDE AND
CAUSTIC LITHIUM OXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.
===================== Ecological Information =====================
Ecological:NO DATA PROVIDED BY RESPONSIBLE PARTY.
==================== Disposal Considerations ====================
Waste Disposal Methods:FULLY DISCHANGE PRIOR TO DISPOSAL. DISPOSE OF IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:APPLICABLE REGULATIONS: 49 CFR 1722.101, 173.185.
PROPER SHIPPING NAME: LITHIUM BATTERY, SOLID CATHODE. CLASS: 9. UN
ID NO.: UN3090. PACKING GROUP: II. LABEL: CLASS 9. AIRCRAFT
LIMITATION: FORBIDDEN. RAILCAR LIMITATION: FORBIDDEN. EXCEPTIONS:
LITHIUM CELLS AND BATTERIES CONTAINING NO MORE THAN 1.0 G LITHIUM
ARE NOT SUJECT TO 49 CFR 173.1855 (REFER 173.185 (I). POWER
CONVERSION PRODUCTS WHICH DO NOT EXCEED THIS LIMIT ARE: BA-5372U;
MO4/U, MO6/1.
===================== Regulatory Information =====================
SARA Title III Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Federal Regulatory Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.
State Regulatory Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.
======================= Other Information =======================
======================================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:906P
CAGE:9V583
CO.
CAGE:9V583
============= Composition/Information on Ingredients =============
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 3%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:N-BUTYL ALCOHOL (SARA III)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 3%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETONE (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 21%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 16%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPYLENE GLYCOL MONOMETHYL ETHER ACETATE
CAS:108-65-6
RTECS #:AI8295000
Fraction by Wt: 6%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:100 PPN
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:INGESTION; GASTROINTESTIONAL DISTRESS,
CALL A PHYSCIAN. INHALATION; NOSE AND THROAT IRRITATION,NERVOUIS
SYSTEM DISORDER CHARACTERIZED BY HEADACHE,DIZZINESS
NAUSEA,STAGGERING GAIT,CONFUSION THEN UNCONS
CIOUNESS.SKIN/EYE;IRRITATION OR BURNINGOF EYES.DISCOMFORT OR
DERMITITIS.
Effects of Overexposure:INTENTIONAL MISUSE BY DELIBERATING
CONCENTRATING AND INHALING THE MATERIAL MAY BE HARMFUL OR
FATAL.WITH PERMANET BREAIN AND NERVOUS SYSTEM DAMAGE.
Medical Cond Aggravated by Exposure:NOT GIVEN
======================= First Aid Measures =======================
First Aid:IGESTION;CALL A PHYSCIAN. INHALATION;REMOVE TO FRESH AIR,IF
NOT BREATHING, GIVE ARTIFICAL RESPIRATION,IF BREATHING DIFFICULTY
PRESISIT OR OCCURS LATER CALL A PHYSCIAN. SKIN/EYES;FLUSH EYES WITH
FOR 15 MINUTES WITH PLENTY OF WATEER CALL A PHYSCIAN,WASH SKIN
WIYH SOAP AND WATER,IF IRRITATION PERSIST CALL A PHYSCIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-20F,-29C
Lower Limits:0.8
Upper Limits:13.1
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:FULL PROTECTIVE CLOTHING, INCLUDING SCBA IS
RECOMMENDED. WATER FROM FOG NOZZLES MAY BE USED TO COOL CLOSED
CONTAINERS TO PREVENT PRESSURE BUILD UP.
Unusual Fire/Explosion Hazard:CONTENTS UNDER PRESSURE, KEEP AT ROOM
TEMPERATURE, FINE MISTA OR SPRAYS MAY BE FLAMMABLE AT TEMPERATURES
BELOW THE FLASH POINT.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA,REMOVE SOURCES OF IGNITION,
PREVENT SKIN CONTACT AND BREATHING OF VAPORS, CONFINE AND REMOVE
WITH INERT ABSORBENT MATERIAL.
Neutralizing Agent:NA
======================Handling and Storage ======================
Handling and Storage Precautions:OBSERVE LABEL PRECAUTIONS.KEEP AWAY
FROM HEAT, SPARKS OR FLAME.DO NOT STORE ABOVE 120F.
Other Precautions:DO NOT SAND, FLAME CUT,BRAZE OR WELD DRY
COATINGWITHOUT APPROVED NIOSH/MSHA RESPIRATOR.DO NOT PUNCTURE CANS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DO NOT BREATH VAPORS OR MISTS. WEAR AN
APPROPIATE PROPERLY FITTED VAPOR/PARTICLE NIOSH/MSHA APPROVE
RESPIRATOR.
Ventilation:PROVIDE SUFFICENT VENTILATION TO KEEP TLV BELOW ALLOWABLE
LIMITS.
Other Protective Equipment:NEIPRENE APRON
Work Hygienic Practices:WASH HANDS AFTER USINGS
Supplemental Safety and Health
PROTECTIVE CREAMS MAY BE USED FOR CLEAN -UP NOT PROTECTION.
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:0F,-18C
Vapor Pres:NOT GIVEN
Vapor Density:> AIR
Spec Gravity:NOT LISTED
Evaporation Rate & Reference:> ETHER
Solubility in Water:MODERATE TO APPRECIE
Appearance and Odor:YELLOW LIQUID,PAINT ODOR
Percent Volatiles by Volume:92
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:DO NOT STORE ABOVE 120F
Hazardous Decomposition Products:CO,CO2,SMOKE, OXIDES OF HEAVY METALS./
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND.
INCINERATE ABSORBED MATERIALS IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REQUIREMENT. DO NOT INCINERATE IN CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:INT/EXT LATEX
CAGE:06758
CAGE:06758
CAGE:23526
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIA
CAS:7664-41-7
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:50 PPM
ACGIH TLV:25 PPM/35 STEL; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:CLAY
CAS:22708-90-3
Fraction by Wt: 20%
Other REC Limits:NONE SPECIFIED
OSHA PEL:NOT SPECIFIED
ACGIH TLV:NOT SPECIFIED
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:WATER
CAS:7732-18-5
Fraction by Wt: 50%
Other REC Limits:NONE SPECIFIED
OSHA PEL:NOT SPECIFIED
ACGIH TLV:NOT SPECIFIED
Ingred Name:CHEMICAL
Fraction by Wt: 20%
Other REC Limits:NONE SPECIFIED
OSHA PEL:NOT SPECIFIED
ACGIH TLV:NOT SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:ACUTE: NONE KNOWN. CHRONIC: WARNING!
THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA
TO CAUSE CANCER AND BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN OR
RESPIRATORY CONDITION MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MIN. SKIN: WASH WITH SOAP AND
WATER. INHALATION: NO PROBLEM AT NORMAL TEMPERATURE. INGESTION: GET
MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:205F,96C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, AND/OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS MUST WEAR SELF CONTAINED
BREATHING APPARATUS OR AIR MASKS. CONTAINERS EXPOSED TO FIRE SHOULD
BE KEPT COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE SPILLS WITH INERT
ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED. DO NOT STORE
ABOVE 120F. KEEP FROM FREEZING. EMPTY CONTAINERS MAY CONTAIN
PRODUCT RESIDUE. DO NOT CUT, PUNCTURE OR WELD.
Other Precautions:ALL LABEL WARNINGS MUST BE OBSERVED UNTIL CONTAINER
HAS BEEN CLEANED, RECONDITIONED OR PROPERLY DISPOSED OF.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE, PROPERLY FITTED RESPIRATOR
(NIOSH/MSHA APPROVED) DURING AND AFTER APPLICATION UNLESS AIR
MONITORING VAPOR/MIST LEVELS ARE BELOW APPLICABLE LIMITS. FOLLOW
RESPIRATOR MANUFACTURERS DIR ECTIONS FOR RESIRATOR USE.
Ventilation:REQUIRED WHEN SPRAYING OR APPLYING IN CONFIED AREA.
Other Protective Equipment:PREVENT PROLONGED SKIN CONTACT BY USING
CLEAN WORK CLOTHING, INCLUDING A HAT.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING OR USING
WASHROOM FACILITIES. DO NOT WEAR CONTAMINATED CLOTHING OR FOOTWEAR.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:24.0 @ 77F
Vapor Density:.6
Spec Gravity:1.21
Evaporation Rate & Reference:.4
Solubility in Water:YES
Appearance and Odor:NORMAL FOR A COATINGS PRODUCT
Percent Volatiles by Volume:80.18
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID WATER-REACTIVE MATERIALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:SILICON DIOXIDE, CARBON DIOXIDE,
CARBON MONOXIDE, METAL OXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN CHEMICAL DISPOSAL AREA OR IN A MANNER
THAT COMPLIES WITH ALL LOCAL, STATE AND FEDERAL REGULATIONS. DO NOT
INCINERATE CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FFLCGRGBL-USC-EK1-1, USC EASI-KLEEN 1 6X1 C
Preparer's Name:C. WERNER
CAGE:FORMU
CAGE:FORMU
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPYL ALCOHOL. VP:33 @ 68F.
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: <5%
OSHA PEL:400 PPM;500 PPM STEL
ACGIH TLV:400 PPM;500 PPM STEL
Ingred Name:ETHANOL, 2-BUTOXY-; (ETHYLENE GLYCOL MONOBUTYL ETHER)
(EGBE). VP:0.6 @ 68F.
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 2%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:RPTD OVEREXP MAY CAUSE DMG TO LIVER,
KIDNEYS, LUNGS & RED BLOOD CELLS CAUSING BLOOD IN URINE.
INHAL:INHAL OF HIGH CONCS MAY CAUSE HDCHS, NAUS, VOMIT/COMA.
EYES:LIQ & MISTS WILL IRRIT & MAY DMG EYES, C AUSING CORNEAL
INJURY. SKIN:NO IRRIT ISLIKELY AFTER BRIEF CONT BUT MAY BE IRRIT
AFTER PRLNG CONT. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:REDNESS, DRYING/OTHER SIGNS OF
IRRIT/CONT DERM. MAY RESULT IN PRIMARY IRRIT DERM. EGBE IS READILY
ABSORBED THRU SKIN CAUSING HDCHS, NAUS, VOMIT, DIARR, COMA.
INGEST:SWALLOWING LG QTYS MAY CAU SE HDCHS, NAUS, VOMIT, DIARR &
MAY CAUSE RED BLOOD CELL HEMOLYSIS, LIVER, KIDNEY & LUNG INJURY.
ANIMAL STUDIES (SUPDAT)
Medical Cond Aggravated by Exposure:PERSONS W/PRE-EXISTING DERMATITIS
MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THIS MATERIAL.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. GIVE ARTF RESP IF NOT BRTHG. GET
MD IMMED. EYES:FLUSH IMMED W/LG AMTS OF H*2O FOR @ LST 15 MINS
HOLDING EYELIDS OPEN. GET MD. SKIN:IMMED FLUSH W/LOTS OF RUNNING
H*2O FOR @ L ST 15 MINS. REMOVE CONTAM CLTHG & SHOES. INGEST:IF
CONSCIOUS, DRINK 2 GLASSES OF H*2O. CALL MD/POIS CTL CTR IMMED.
TREAT SYMPTOMATICALLY. DO NOT GIVE ANYTHING BY MOUTH TO
UNCON/CONVULSING PERSON.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:NONE
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . USE WATER SPRAY TO COOL NEARBY CONTAINERS &
STRUCTURES EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FOR SMALL SPILLS DILUTE W/WATER, MOP/WIPE UP &
CONTAIN. FOR LARGE SPILLS, CONTAIN BY DIKING W/ABSORBENT MATERIAL &
CONTAIN. KEEP MATERIAL OUT OF SEWERS, STORM DRAINS, SURFACE WATERS
& SOIL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN DRY, WELL VENTED PLACE AWAY
FROM INCOMPAT MATLS. KEEP CNTNR TIGHTLY CLSD WHEN NOT IN USE. STORE
@ TEMPS >SOLNS FREEZING POINT TO REMAIN LIQ.
Other Precautions:DO NOT USE PRESSURE TO EMPTY CONTAINER. CONTAINERS,
EVEN THOSE THAT HAVE BEEN EMPTIED, WILL RETAIN PRODUCT RESIDUE &
VAPORS. ALWAY OBEY HAZARD WARNINGS & HANDLE EMTPY CONTAINERS AS IF
THEY WERE FULL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED WHEN USING THIS PRODUCT IN
DILUTED FORM PER DIRECTIONS. WEAR NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR THE VAPOR OR MIST CONCENTRATION AT THE POINT OF
USE.
Ventilation:USE ADEQUATE MECHANICAL (GENERAL &/OR LOCAL) VENTILATION TO
MAINTAIN EXPOSURE BELOW PEL.
Other Protective Equipment:WEAR APPROPRIATE PROTECTIVE CLOTHING,
INCLUDING RESISTANT CLOTHING, RUBBER BOOTS W/PANTS ON OUTSIDE.
Work Hygienic Practices:WASH HANDS BEFORE EATING/USING RESTROOM. REMOVE
& WASH CONTAM CLTHG BEFORE REUSE. WEARING CONT LENSES IS NOT (SUPP
DATA)
Supplemental Safety and Health
EFTS OF OVEREXP:HAVE CLEARLY DEMONSTRATED DOSE-RELATED ADVERSE EFTS ON
CNS, HEMPTOPOIETIC TISS, BLOOD, KIDNEYS & LIVER ASSOC W/ADMIN OF
ETHYLENE GLYCOL MONOBUTYL ETHER (EGBE). (EXTRACTED FROM DHHS (NI
OSH) PUBLICATION NO. 90-118). . HYGIENE PRACT:RECOMMENDED WHILE
USING.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1 (H*2O=1)
pH:8-10
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT BLUE LIQUID, NON-VISCOUS, FAINT SWEET ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:MAY LIBERATE CO, CO*2 & SO*X.
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY W/ALL APPLIC GOVT REGS ON SPILL
REPORTING, HNDLG & DISP OF WASTE. DISP OF CONTAM PROD & MATLS USED
IN CLEAN UP IN MANNER APPRVD FOR MATL. CONSULT APPROP FED, STATE &
LOC REGULATORY AGENCIES TOASCERTAIN PROPER DISP PROCS & COMPLY
W/THEM.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:0900 UNLEADED GASOLINE, 87 OCTANE
CAGE:3V260
CAGE:3V260
============= Composition/Information on Ingredients =============
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:WARNING!MAY CAUSE CARDIAC
SENSITIZATION.ASPIRATION HAZ IF SWALLOWED-CAN ENTER LUNGS & CAUSE
DMG.OVEREXPO MAY CAUSE CNS DEPRESS.MAY BE IRRIT TO SKIN/EYES/RESP
TRACT.POTENTIAL CANCER HAZ.CONTAINS BENZEN E--KNOWN HUMAN
CARCINOGEN.INGEST:SLIGHTLY TOXIC.IRRIT OF MOUTH/THROAT/GI
TRACT.SKIN:SLIGHTLY IRRIT.DEFAT AGENT.(SUPPLEM)
Explanation of Carcinogenicity:CONTAINS B[71-43-2] WHICH IS
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:INGEST:SALV,PAIN,NAU,VOMIT,DIARR.ASPIRATION
INTO LUNGS MAY CAUSE CHEM PNEU/LUNG DMG.OVEREXPO MAY CAUSE SYSTEMIC
DMG INCLUDING TARGET ORGAN EFFECTS
KIDNEY,LIVER,CNS.SKIN:DRYING,REDDENING,ITCH,PAIN,INFL AMM,CRACK,2ND
INFECTION W/TISSUE DMG.INHAL:CARDIAC SENS,ARRHYTHMIAS,DEATH FRM
CARDIAC ARREST.
Medical Cond Aggravated by Exposure:PRE-EXISTING MED CONDITIONS WHICH
MAY BE AGGRAVATED BY EXPOSOURE INCLUDE DISORDERS OF SKIN, KIDNEY,
LIVER & RESP TRACT.
======================= First Aid Measures =======================
First Aid:INGEST:DO NOT INDUCE VOMIT-ASPIRATION HAZ.IF SPONT KEEP HEAD
BELOW HIPS.MONITOR BREATH.KEEP WARM/@REST.GASTRIC LAVAGE.SKIN:IMMED
WASH W/PLENTY OF SOAP/WATER WHILE REMOVE CONTMAIN
CLOTH/SHOE.EYE:FLUSH IMMED W/LG AMTS OF WATER @LEAST 15MINS,OPN
EYELIDS.INHAL:REMOVE TO FRESH AIR.NOT BREATH GIVE CPR.BREATH DIFFI
CLEAR AIRWAY/GIVE OXY.KEEP WARM/@REST.IN ALL CASES IRRIT
PERSIST/DEVELOPS GET IMMED MED AT
===================== Fire Fighting Measures =====================
Flash Point:-40F,-40C
Lower Limits:1.4
Upper Limits:7.6
Extinguishing Media:NONE SPECIFIED BY MANUFACTURER.
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard:DANGER!EXTREMENLY FLAMM.VAP MAY CAUSE
FLASH FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGN SOURCES.ISOLATE HAZ AREA/DENY
ENTRY.TAKE IMMED STEPS TO STOP/CONTAIN SPILL.EXERCISE CAUTION
REGARDING PERSONNEL SAFT/EXPO.NOTIFY PROPER
AUTHORITIES;RQ=333LBS.ABSORB W/INERT MATL.PLACE I N CHEM WASTE
CNTNR.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE TIGHTLY CLSD CNTNR @COOL DRY
ISOLATED WELL VENTI AREA AWAY FRM HEAT/IGN SOURCES/INCOMP.AVOID
STRG OXIDIZERS CONTACT.DON'T EAT/SMOK/DRK NEAR MATL
Other Precautions:GROUND LINES/EQPMT WHEN TRANSFER PROD.USE OF ANY
HYDROCARBON FUEL IN AREA W/O ADEQUA VENTI MAY RESULT IN HAZ COMBUST
PROD/INADEQUA OXY LEVELS.GASOLINE ONE OF SOLVTS USED BY CHEM SUBST
ABUSERS;PRESENT ACUTE/CHRONIC CNS SIGNS/SYMP/ARRHYTHMIAS
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED AIR PURIFYING RESP (LIMITED
PROT)W/ORG VAP CARTRIDGE/CANISTER MAY BE PERMISSIBLE UNDER CERTAIN
CIRCUMSTANCES WHERE AIRBORNE CONCEN EXPECTED TO EXCEED EXPO
LIMITS.USE +PRESS AIR SUP PLIED RESP FOR UNK CONCEN/ADEQU PROTECT
Ventilation:VENTILATION & OTHER FORMS OF ENGINEERING CONTROLS ARE
PREFERRED MEANS FOR CONTROLLING EXPOSURES.
Other Protective Equipment:EYEWASH FACILITY.USE GOOD PERSONAL
HYGIENE.USE NON-SPARKS TOOL.
Work Hygienic Practices:LAUNDER/DISCARD CONTAMIN CLOTH;MEANWHILE KEEP
IN CLSD CNTNR.INFORM CLEANERS OF CONTMAIN.DISCARD CONTAMIN LEATHER
GOODS.
Supplemental Safety and Health
HEALTH HAZ:REPEAT/PROLONG CONTACT W/LG AMTS OF MATL MAY RESULT IN
ABSORPTION THRU SKIN TO PRODUCE TOXIC EFFECTS.EYE:SLIGHT TRANSIENT
IRRIT,LACRIMATION,BURNING SENSATION.IRRIT/CONJUCNTIVITIS.INHAL:NON
TO SLIGHTLY TOXIC.IRRIT NOSE/THROAT/LUNGS.CNS DEPRESS. EMPTY CNTNRS
CONTAIN PROD RESIDUE-TAKE NECESSARY PRECAUTIONS.
================== Physical/Chemical Properties ==================
HCC:F1
Boiling Pt:B.P. Text:90.0F,32.2C
Melt/Freeze Pt:M.P/F.P Text:-130F,-90C
Vapor Pres:348-698
Vapor Density:3-4
Spec Gravity:0.73
pH:NEUTRA
Evaporation Rate & Reference:MODERATELY FAST, WATER=1
Solubility in Water:NEGLIGIBLE.
Appearance and Odor:CLEAR, COLORLESS LIQUID W/SHARP, PENETRATING,
AROMATIC ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE W/OXIDIZING AGENTS.
Stability Condition to Avoid:ALL SOURCES OF IGNITION.
Hazardous Decomposition Products:COMBUSTION MAY PRODUCE CO, NOX, SOX &
REACTIVE HDYROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:AS SUPPLIED HAZ WASTE DUE TO BENZENE &
IGNIT.DISPOSE IAW 40CFR IN PROPERLY PERMITTED FACIL.CHECK STATE/LOC
REGS.CHEM ADDN/PROCESSING/ALTERING MATL MAKE WASTE MANAGEMENT INFO
PRESENT INCOMPLETE/INACCUT /INAPPROP.DISPOSE OF IAW ALL
FED/STATE/LOC REGS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EC-423-2 HARDENER
CAGE:JO406
CAGE:JO406
CAGE:66058
============= Composition/Information on Ingredients =============
Ingred Name:METHYLAMINE, M-PHENYLENEBIS-; (M-XYLENEDIAMINE)
CAS:1477-55-0
RTECS #:PF8970000
Fraction by Wt: <35%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:EPOXY RESIN; (BISPHENOL A BASED EPOXY RESIN)
CAS:25085-99-8
Fraction by Wt: <30%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ISOPHORONEDIAMINE
CAS:2855-13-2
RTECS #:GV6129000
Fraction by Wt: 25-35%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:IMIDAZOLE, 1-METHYL-; (1-METHYLIMIDAZOLE)
CAS:616-47-7
RTECS #:NI7000000
Fraction by Wt: <7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:1,6-HEXANEDIAMINE, 2,2,4-TRIMETHYL; (TRIMETHYLHEXAMETHYLENE
DIAMINE)
CAS:3236-53-1
Fraction by Wt: <3%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:POSSIBLE ALLERGIC RESPONSE,
METHEMOGLOBINEMIA AND LIVER DAMAGE. REDNESS AND SWELLING OF
AFFECTED AREAS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NOT DETERMINED.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. CONTACT MD.
SKIN: WASH WITH MILD SOAP AND WATER. INHALATION: REMOVE FROM
CONTAMINATED AREA TO FRESH AIR. INGESTION: DO NOT INDUCE VOMITING;
GIVE LARGE A MOUNTS OF WATER OR MILK AND CONTACT MD.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F,>93C
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, FOAM, CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . AVOID EYE AND SKIN CONTACT. DO NOT BREATHE FUMES.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE TO KEEP OUT OF DRAINS. ABSORB WITH INERT
MATERIALS SUCH AS SAND, CLAY AND DIRT. AVOID SAWDUST AND CELLULOSE.
FLUSH RESIDUE WITH WARM WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT AMBIENT TEMPERATURE IN A WELL
VENTILATED AREA AWAY FROM EXCESSIVE HEAT OR OPEN FLAMES.
Other Precautions:NONE KNOWN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR WITH ORGANIC VAPOR
CARTRIDGE.
Ventilation:LOCAL EXHAUST RECOMMENDED. MECHANICAL (GENERAL) IS USUALLY
ADEQUATE.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
CLEAN, BODY COVERING CLOTHING.
Work Hygienic Practices:PRACTICE GOOD HYGIENE AND USE WITH CAUTION TO
AVOID EYE OR SKIN CONTACT.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:1.06 (H*2O=1)
Solubility in Water:SLIGHT
Appearance and Odor:AMBER LIQUID WITH MILD ODOR.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS.
Stability Condition to Avoid:REACTIONS WITH EPOXIES UNDER UNCONTROLLED
CIRCUMSTANCES.
Hazardous Decomposition Products:OXIDES OF CARBON AND NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN ADEQUATE INCINERATOR OR BURY IN LANDFILL
IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL LAWS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:METCO405, 405-1, 405NS, 405NS-1 WIRE
Resp. Party Other MSDS Num.:50-215
CAGE:01FK3
CAGE:01FK3
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINIUM
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 20%
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:NICKEL
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 80%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES
Health Hazards Acute and Chronic:ALUMINUM: MAY CAUSE PNEUMOCONIOSIS,
IRRITATION TO THE GASTROINTESTINAL TRACT, PULMONARY, SKIN AND EYE
IRRITANT DUE TO ABRASIVE ACTION. UNDER NORMAL USE/CONDITIONS,
ALUMINUM OXIDE MAY BE FORMED. NICKEL : MAY CAUSE IRRITATION TO
RESPIRATORY SYSTEM, GENERAL NERVOUS SYSTEM DEPRESSION, CANCERS OF
LUNG AND NASAL SINUSES; IRRITATION TO GASTROINTESTINAL TRACT, LOSS
OF MUSCULAR COORDINATION, CONFUSION AND CONVULSIONS. SKIN CONTACT
MAY CAUSE DERMITITIS. EYE CONTACT MAY CAUSE IRRITATION.TARGET
ORGANS: RESPIRATORY SYSTEM.CNS,GASTROINTESTINAL TRACT,SKIN,EYES.
Explanation of Carcinogenicity:NICKEL IS CLASSIFIED AS A CARCINOGEN.
Effects of Overexposure:EYE: POSSSIBLE IRRITATION. SKIN: POSSIBLE
IRRITATION, DERMITITIS. INHALATION: POSSIBLE IRRITATION TO THE
RESPIRATORY SYSTEM. INGESTION: POSSIBLE IRRITATION TO THE
GASTROINTESTINAL TRACT, LOSS OF MUSCU LAR COORDINATION, CONFUSION
AND CONVULSIONS.
Medical Cond Aggravated by Exposure:CONSULT A PHYSICIAN.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH EYES WITH WATER FOR A TLEAST 15-20 MINUTES WHILE
HOLDIG EYELIDS OPEN. IF IRRITATION PERSISTS, CONSULT A PHYSICIAN.
SKIN: WASH WITH SOAP AND WATER. IF IRRITATION PERSISTS, CONSULT
PHYSICIAN . INHALATION: EXPOSE TO FRESH AIR. CONSULT A PHYSICIAN IF
IRRITATION OR RESPIRATORY DISTRESS PERSISTS.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE CLASS D FIRE EXTINGUISHER.
Fire Fighting Procedures:TREAT AS A METALLIC AFIRE. USE NIOSH/MSHA
APPROVED SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE
CLOTHING IF INVOLVED IN FIRE.
Unusual Fire/Explosion Hazard:MODERATE FIRE HAZARD IN THE FORM OF WIRE
WHEN EXPOSED TO FLAME. ALUMINUM IS A FLAMMABLE SOLID, DO NOT EXPOSE
TO WATER OR MOISTURE.
================== Accidental Release Measures ==================
Spill Release Procedures:DRY SWEEP LOOSE/SMALL PIECES OF WIRE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM INCOMPATIBLES. STORE
PRODUCT CONTAINERS IN WELL-VENTILATED, CLEAN, COOL AND DRY AREA.
STORE IN A MANNER TO MINIMIZE PUNCTURES AND BREAKAGE OF CONTAINERS.
Other Precautions:IN THE FORM OF SOLID WIRE, THIS PRODUCT POSES LOW TO
NEGLIGIBLE HAZARDS IN TERMS OF INHALATION, INGESTION AND SKIN
CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A RESPIRATOR APPROVED BY NIOSH WITH FILTER
CARTRIDGES APPROVED FOR DUST/FUMES/MISTS SHOULD BE WORN AT ALL
TIMES DURING THE THERMAL SPRAY PROCESS TO PROTECT THE OPERATOR FROM
EXPOSURE TO DUST AND FUMES . RESPIRATORS MAY ALSO BE WORN WHEN
PRODUCT HANDLING GENERATES DUST.
Ventilation:PRODUCT SHOULD BE USED WITH APPROPRIATE LOCAL EXHAUST
VENTILATION PROVIDED.
DURING HANDLING
HANDLING. (SUP)
Other Protective Equipment:EYEWASH STATION; WASH FACILITY. ALUMANIZED
APRON DURING PLASMA SPRAY PROCESS. OTHE RAPPROPRIATE CLOTHING MAY
BE WORN AS NECESSARY DURING PRODUCT HANDLING TO AVOID EXCESSIVE
CONTACT WITH THE SKIN.
Work Hygienic Practices:EAR PROTECTION WHEN NECESSARY
Supplemental Safety and Health
INDICATED. COMBUSTION SPRAYING SHADE #5, PLASMA SPRAYING UP TO 40KW
SHADE #9, 40-60KW SHADE #10 AND GREATER THAN 60KW SHADE #11.
================== Physical/Chemical Properties ==================
HCC:T6
Melt/Freeze Pt:M.P/F.P Text:1300-2500F
Solubility in Water:INSOLUBLE
Appearance and Odor:WIRE; NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALUMINUM IS INCOMPATIBLE WITH STRONG OXIDIZERS, ACIDS AND HALOGENATED
HYDROCARBONS. NICKEL IS INCOMPATIBLE WITH ACIDS, SULFUR, SELENIUM,
WOOD, OTHER COMBUSTIBLES AND NICKEL NITRATE.
Hazardous Decomposition Products:OZONE AND NITRIC OXIDE ARE FORMED BY
PLASMA FLAME (SIMILAR TO WELDING FUMES). THIS ACTION IS INDEPENDENT
OF METAL WIRE.
==================== Disposal Considerations ====================
Waste Disposal Methods:EMPTY PRODUCT CONTAINERS, PRODUCT WASTE AND
CLEANING MEDIA SHOULD BE STORED AND DISPOSED OF ACCORDING TO THE
APPROPRIATE LOCAL, STATE AND FEDERAL REGULATORY GUIDELINES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:93-118 CURING AGENT,PART A
Kit Part:Y
Preparer's Name:JACK L. SHENEBERGER
CAGE:5D028
CAGE:5D028
CAGE:71984
============= Composition/Information on Ingredients =============
Ingred Name:DIMETHYL, METHYL HYDROGEN SILOXANE COPOLYMER
CAS:68037-59-2
Fraction by Wt: 11%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE EFFECTS:DIRECT CONTACT WITH EYES
MAY CAUSE TEMPORARY DISCOMFORT. CHRONIC EFFECTS:NONE KNOWN.
Explanation of Carcinogenicity:NONE OF THE INGREDIENTS IN THIS PRODUCT
IS LISTED BY NTP, IARC OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYES: MAY CAUSE TEMPORARY DISCOMFORT. SKIN:
SEVERAL, PROLONGED EXPOSURE (HOURS) MAY CAUSE SLIGHT IRRITATION.
INHALATION: NO IRRITATION TO NOSE OR THROAT EXPECT-ED. NO INJURY IS
LIKELY FROM RELATIVELY SHORT EXPOSURE. ORAL: AMOUNTS TRANS-FERRED
TO MOUTH BY FINGERS DURING NORMAL USE SHOULD NOT CAUSE INJURY.
Medical Cond Aggravated by Exposure:MAY ENHANCE ALLERGIC CONDITIONS ON
CERTAIN PEOPLE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER. SKIN: WIPE OFF AND FLUSH WITH
WATER. INHALATION: NO PROBLEM. ORAL: NO PROBLEM:
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>212F,>100C
Autoignition Temp:Autoignition Temp Text:UNKNON
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT MATERIAL TO COLLECT AND CONTAIN
FOR SALVAGE OR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE, HEAT, IGNITION SOURCES AND
INCOMPATIBLE MATERIALS. KEEP CONTAINERS CLOSED.
Other Precautions:PRODUCT EVOLVES MINUTE AMOUNTS OF HYDROGEN GAS. DO
NOT REPACKAGE OR STORE IN UNVENTED CONTAINERS. AVOID EYE AND SKIN
CONTACT. DO NOT BREATHE VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. NIOSH/MSHA-APPROVED
RESPIRATOR OR SCBA AS APPROPIATE FOR EXPOSURE OF CONCERN IF
EXPOSURE LEVELS ARE EXCEEDED.
Ventilation:MECHANICAL (GENERAL) VENTILATION RECOMMENDED.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
KEY1:N1. THIS IS PART A OF A 2-PART KIT FOR PART B, SEE PNI B, SAME
NSN. CONTACT WITH WATER, SOME METALS, ACIDS OR BASES MAY LIBERATE
FLAMMABLE, EXPLOSIVE HYDROGEN GAS.
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Pres:<5
Spec Gravity:0.8
Solubility in Water:<0.1
Appearance and Odor:LIQUID, VERY LITTLE ODOR, SOME COLOR.
Percent Volatiles by Volume:<5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, ALCOHOL, ACIDIC OR BASIC MATERIALS, MANY METALS OR METALLIC
COMPOUNDS, OXIDIZING MATERIAL.
Stability Condition to Avoid:HUMIDITY.
Hazardous Decomposition Products:SILICON DIOXIDE, CARBON DIOXIDE, AND
TRACES OF INCOMPLETELY BURNED CARBON PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL
REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:741-410
CAGE:09869
CAGE:09869
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA (PETROLEUM SPIRITS OR BENZIN)
CAS:8030-30-6
RTECS #:SE7555000
Fraction by Wt: <38%
OSHA PEL:100 PPM
Ingred Name:LEAD CHROMATE
Fraction by Wt: 4.0%
===================== Hazards Identification =====================
Effects of Overexposure:INHALE: ANESTHETIC,IRRITATION OF RESPIRATORY
TRACT,ACUTE NERVOUS SYSTEM DEPRESSION CHARACTERIZED BY
======================= First Aid Measures =======================
First Aid:INCASE OF CONTACT,FLUSH SKIN AND EYES WITH PLENTY OF WATER
WHILE REMOVING CONTAMINATED CLOTHING. IF INHALED, REMOVE TO FRESH
AIR. CALL A PHYSICIAN IF SYMPTOMS PERSIST.
===================== Fire Fighting Measures =====================
Flash Point:86F, 30C TCC
Lower Limits:1.1
Extinguishing Media:CARBON DIOXIDE/DRY CHEMICAL-SMALL; POLYMER
FOAM-LARGE FIRE
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS AVAILABLE
FOR FIREMEN
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS EXPOSED TO HEAT MAY
EXPLODE DUE TO PRESSURE BUILD-UP
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION (FLAMES, HOT
SURFACES, AND ELECTRICAL, STATIC, OR FRICTIONAL SPARKS). AVOID
BREATHING VAPORS. VENTILATE AREA. REMOVE WITH INERT ABSORBENT AND
NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. STORE LARGE
QUANTITIES IN BUILDINGS DESIGNED AND PROTECTED FOR STORAGE OF NFPA
CLASSONE FLAMMABLE (OR COMBUSTIBLE) LIQUID.
Other Precautions:DO NOT TAKE INTERNALLY,CONTAINERS SHOULD BE GROUNDED
WHEN POURING,AVOID FREE FALL IN EXCESS OF A FEW INCHES,DO NOT
FLAMECUT,BRAZE, OR WELD COATED MATERIAL WITHOUT VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:APPROVED BUREAU OF MINES RESPIRATORS W/PROPER
FILTER OR HOOD
Ventilation:GENERAL DILUTION/LOCAL EXHAUST FOR TLV&LEL SAFETY& WELDING
Other Protective Equipment:PREVENT PROLONGED SKIN CONTACT TO
CONTAMINATED CLOTHING.
Supplemental Safety and Health
BOILING POINT 155-189C. EFFECTS OF OVEREXPOSURE - HEADACHE, DIZZINESS
ETC. OR COMA. PRIMARY IRRITATION FOR SKIN OR EYE CONTACT. LEAD
CHROMATE (AOT-LD50) 10 (GM/KG)
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:311-373F
Evaporation Rate & Reference:< ETHER
Percent Volatiles by Volume:59.0
================= Stability and Reactivity Data =================
Stability Condition to Avoid:FIRES, HEAT, AND HOT SURFACES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS. INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NICKEL BASED ALLOY STEEL, INCONEL ALLOY 7XX
CAGE:11045
CAGE:11045
============= Composition/Information on Ingredients =============
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 39-80%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
Ingred Name:NIOBIUM
CAS:7440-03-1
Fraction by Wt: <5%
Ingred Name:TANTALUM
CAS:7440-25-7
RTECS #:WW5505000
Fraction by Wt: <2%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3; DUST; 9192
Ingred Name:TITANIUM
CAS:7440-32-6
RTECS #:XR1700000
Fraction by Wt: <3%
Ingred Name:TUNGSTEN
CAS:7440-33-7
RTECS #:YO7175000
Fraction by Wt: <5%
OSHA PEL:5 MG/M3/ 10 STEL
ACGIH TLV:5 MG/M3/10 STEL;9192
Ingred Name:YTTRIUM
CAS:7440-65-5
RTECS #:ZG2980000
Fraction by Wt: <1%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
Ingred Name:ALUMINUM (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: <5%
OSHA PEL:15MG/M3 DUST/5 FUME
ACGIH TLV:10MG/M3 DUST; 9192
Ingred Name:CHROMIUM (SARA III)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 15-48%
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:COBALT (SARA III)
CAS:7440-48-4
RTECS #:GF8750000
Fraction by Wt: 0-13%
OSHA PEL:0.1 MG/M3;AS CO
ACGIH TLV:0.05 MG/M3;DUST 9293
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: 1-40%
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: <5%
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
Fraction by Wt: 2-10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SHORT TERM EXPOS TO FUMES/DUST MAY
PRODUCE IRRIT OF EYES & RESP SYS. INHAL OF HIGH CONC OF FRESHLY
FORMED OXIDE FUMES OF IRON, MANGANESE & COPPER MAY CAUSE METAL FUME
FEVER CHARACTERIZED BY METALLIC T ASTE IN MOUTH, DRYNESS & IRRIT OF
THROAT & INFLUENZA LIKE SYMPS. CHRONIC INHAL OF HIGH CONC OF (EFTS
OF OVEREXPOSURE)
Explanation of Carcinogenicity:NICKEL:GROUP 2 (NTP), GROUP 1 (IARC).
CHROMIUM:GROUP 1 (NTP), GROUP 1 (IARC).
Effects of Overexposure:HLTH HAZ:IRON OXIDE FUMES/DUST MAY LEAD TO A
BENIGN PNEUMOCONIOSIS (SIDEROSIS). INHAL OF HIGH CONC OF FERRIC
OXIDE MAY POSS ENHANCE RISK OF LUNG CANCER DEVELOPMENT IN WORKERS
EXPOSED TO PULM CARC. REC ENT EPIDEMIOLOGICAL STUDIES OF WORKERS
MELTING & WORKING ALLOYS CNTNG NICKEL/CHROMIUM HAVE FOUND NO INCR
(SEE SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:GET MD IMMEDIATELY. EYE:FLUSH WITH WATER FOR AT LEAST
15 MINUTES. SKIN:FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST
15 MINUTES. CALL MD . INGEST:CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:NOT APPLICABLE. USE MEDIA SUITABLE FOR SURROUNDING
FIRE CONDITIONS .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . STEEL PRODUCTS IN THE SOLID STATE PRESENT NO
FIRE OR EXPLOSION HAZARD.
Unusual Fire/Explosion Hazard:NOT APPLICABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:NOT APPLICABLE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:IN WELDING, PRECAUTIONS SHOULD BE
TAKEN FOR AIRBORNE CONTAMINANTS WHICH MAY ORIGINATE FROM COMPONENTS
OF THE WELDING ROD.
Other Precautions:ARC OR SPARK GENERATED WHEN WELDING OR BURNING COULD
BE A SOURCE OF IGNITION FOR COMBUSTIBLE AND FLAMMABLE MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED DUST AND FUME, RESPIRATOR
SHOULD BE USED TO AVOID EXCESSIVE INHALATION OF PARTICULATES WHEN
EXPOSURE EXCEEDS TLV'S.
Ventilation:LOCAL EXHST VENT SHOULD BE UTILIZED WHEN WELDING, BURNING,
SAWING, BRAZING, GRINDING/MACHINING WHEN EXPOS EXCEEDS TLV'S.
Other Protective Equipment:OTHER PROTECTIVE EQUIPMENT SHOULD BE
UTILIZED AS REQUIRED BY THE WELDING STANDARDS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HLTH HAZ:INCREASED RISK OF CANCER EXPOSURE TO HIGH CONCENTRATION OF
NICKEL/CHROMIUM DUST OR FUMES CAN CAUSE SENSITIZATION DERMATITIS,
INFLAMMATION AND/OR ULCER OF UPPER RESPIRATORY TRACT AND POSSIBLE
CANCER OF NASAL PASSAGES AND LUNGS.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:>2300F
Spec Gravity:7
Appearance and Odor:GRAY-BLACK SOLID; ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTS WITH STRONG ACIDS TO PRODUCE HYDROGEN GAS.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:METALLIC DUST OR FUMES MAY BE PRODUCED
DURING WELDING, BURNING, GRINDING, AND POSSIBLY MACHINING. REFER TO
ANSI Z49.1.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH ALL LOCAL,
STATE, AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:METREGRID 303MV ACTIVATOR
Kit Part:Y
CAGE:18604
CAGE:18604
============= Composition/Information on Ingredients =============
Ingred Name:POLYAMIDE RESINS
===================== Hazards Identification =====================
Effects of Overexposure:EXTREMELY IRRITATING TO EYES. MILD SKIN
IRRITANT.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH IMMED W/PLENTY OF H*2O FOR @ LEAST 15 MIN.SEE EYE
PHYSICIAN.SKIN:WIPE OFF EXCESS.RINSE WITH 5% ACETIC AICD
(MFR),SCRUB WITH SOAP & H*2O.WASH CLOTHING BEFORE
REUSE.INHAL:REMOVE TO FRESH AIR.G IVE O*2 & ARTIFICIAL RESP IF
NECESS.(SEE OTHR PREC
===================== Fire Fighting Measures =====================
Flash Point:509F (265C), COC
Extinguishing Media:CO*2,DRY CHEMICAL,CHEMICAL FOAM.
Fire Fighting Procedures:USE SCBA.CLASS B LIQUID.
Unusual Fire/Explosion Hazard:NONE KNOWN. HANDLE AS A COMBUSTIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP UP EXCESS.SCRUB WITH 5% ACETIC ACID
(MFR).RINSE WITH VERY HOT H*2O.AVOID DIRECT CONTACT.FLUSH
CONTAMINATED AREA WITH H*2O.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT LEAVE CONTAINERS OPEN.
Other Precautions:EMER & FIRST AID PROC: CALL PHYSICIAN. INGEST: NOT
LIKELY A HAZARD.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC
VAPORS.
Ventilation:MECHANICAL(GENERAL) VENTILATION ACCEPTABLE.
Supplemental Safety and Health
DATE OF PREP:OCTOBER,1982. PART A OF A TWO PART KIT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:DECOMPOSES
Spec Gravity:1.0
Evaporation Rate & Reference:N/A (BUTYL ACETAT)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TAN VISCOUS LIQUID.
Percent Volatiles by Volume:0.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CO &/OR CO*2,NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IAW FEDERAL,STATE & LOCAL REGULATIONS.
INCINERATE WHERE PERMITTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EPOXY TA-10N PART A
Kit Part:Y
Preparer's Name:BETTY RAY
CAGE:IDIAD
CAGE:IDIAD
============= Composition/Information on Ingredients =============
Ingred Name:TALC (POWDER) CONTAINING NO ASBESTOS FIBERS
CAS:14807-96-6
RTECS #:WW2710000
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:CALCIUM CARBONATE; (GROUND LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:SUPP DATA: IRRIT, POSS CORNEAL INJURY. CHRONIC: NONE
ESTABLISHED. INHAL: ACUTE: OVEREXP TO VAP CONC MAY CAUSE (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: DIZZ, NARCOS, RESP IRRIT & LUNG DAM. CHRONIC: NONE
ESTABLISHED.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: WASHING, GET MED ATTN. CONT LENSES SHOULD
NOT BE WORN WHEN WORKING W/PROD. INHAL: MOVE TO FRESH (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:AIR @ ONCE. IF BRTHG CONTINUES TO BE DFCLT,
ADMINISTER OXYGEN UNTIL MED ASSIST CAN BE RENDERED. IF BRTHG (ING
11)
RTECS #:9999999ZZ
Ingred Name:ING 10:STOPS, BEGIN ARTF RESP. KEEP AFFECTED PERSON WARM &
@ REST. GET MED ATTN AS SOON AS POSSIBLE.
RTECS #:9999999ZZ
Ingred Name:VENT: IF LOC EXHAUST VENT IS PROVIDED. IF ROOM AIR IS NOT
RECIRCULATED, BUT EXHAUSTED, MAY BE ADEQ. OTHER: (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:USE EXPLOSION PROOF MOTOR & FIXTURES ONLY.
RTECS #:9999999ZZ
Ingred Name:HYGIENE PRACT: SHOULD NOT BE WORN.
RTECS #:9999999ZZ
Ingred Name:BISPHENOL A DIGLYCIDL ETHER RESIN; (BISPHENOL A EPOXY
RESIN)
CAS:25068-38-6
RTECS #:SL6475000
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:ALIPHATIC GLYCIDYL ETHER; (ALKYL GLYCIDYL ETHER)
CAS:68609-97-2
Ingred Name:MINERAL OIL, PETROLEUM EXTRACTS, HEAVY NAPHTHENIC
DISTILLATE SOLVENT; (PETROLEUM PROCESS OIL)
CAS:64742-11-6
RTECS #:PY8042000
OSHA PEL:5 MG/M3 (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INGEST: ACUTE: UNLIKELY RTE OF EXPOS.
CHRONIC: NONE ESTABLISHED. SKIN: ACUTE: PRLNGD/RPTD CONT MAY CAUSE
PRIMARY IRRIT & SENSIT. CHRONIC: LIFETIME SKIN PAINTING STUDIES
CONDUCTED BY IARC HAVE SHOWN TH AT THIS TYPE OF PROD CAUSES SKIN
CANCERIN TEST ANIMALS. SUBSTANCE WAS APPLIED TO SHAVED BACKS OF
MICE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:CAS # 64742-11-6: GROUP 1, IARC
MONOGRAPHS VOLUME SUPPLEMENT 7, PAGE 252, 1987 .
Effects of Overexposure:HLTH HAZ:@ REGULAR INTERVALS, W/OUT CLEANUP
BETWEEN APPLICATN. IN VIEW OF THESE FINDINGS, THERE MAY BE A POTNTL
RISK OF SKIN CANCER IN HUMANS FROM PRLNGD/RPTD SKIN CONT W/PROD IN
ABSENCE OF GOOD PERSO NAL HYGIENE. LIM STUDIES ON OILS THAT ARE
VERY ACTIVE CARCIN HAVE SHOWN THAT WASHING ANIMALS' SKIN W/SOAP &
(SUPP DATA)
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS.
======================= First Aid Measures =======================
First Aid:INGEST: DO NOT INDUCE VOMIT. GET MED ATTN. SKIN: WASH CONTAMD
AREA W/SOAP & WATER/SKIN CLEANSER. IF IRRIT PERSIST AFTER WASH, GET
MED ATTN. IF PROD SOAKS THRU CLTHG, REMOVE CLTHG IMMED & WASH
AFFECTED AREA. WET CLTHG SHOULD BE PLACED IN A SFTY CONTR & NOT
REWORN UNTIL CLTHG HAS BEEN LAUNDERED. EYES: WASH IMMED W/LG AMTS
OF WATER FOR @ LST 15 MIN, LIFT LIDS OCCAS. IF IRRIT PERSIST AFTER
(ING 9)
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>200F,>93C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, HALON.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:COOL DRUMS WITH WATER SPRAY TO PREVENT
EXPLOSION. VAPOR MAY IGNITE EXPLOSIVELY.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE & ELIM ALL SOURCES OF IGNIT. VENT AREA
OF SPILL/LEAK. FOR SM QTY ABSORB ON PAPER TOWELS. LG QTY SHOULD BE
RETAINED BY DIKING & ABSORBED W/ABSORBENT MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP PRODUCT CONTAINERS COOL, DRY AND
AWAY FROM SOURCES OF IGNITION. USE AND STORE THIS PRODUCT WITH
ADEQUATE VENTILATION.
Other Precautions:PRODUCT SHOULD NOT BE ALLOWED TO ENTER A CONFINED
SPACE, SUCH AS A SEWER, BECAUSE OF POSSIBILITY OF VAPOR BUILD-UP,
POSSIBLY ALLOWING AN EXPLOSION. PERSONS SHOULD AVOID BREATHING
VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOS MAY/DOES EXCEED OCCUPATIONAL EXPOSURE
LIMITS USE A NIOSH/MSHA APPROVED RESPIRATOR TO PREVENT
OVEREXPOSURE. USE EITHER A NIOSH/MSHA APPRVD SELF-CNTND AIR
SUPPLIED RESP OR ORGANIC VAPOR RESPIRA TOR IN ACCORDANCE WITH 29CFR
1910.134.
Ventilation:LOC EXHAUST: YES, GENERALLY REQD TO REDUCE EXPOS TO BELOW
OSHA ALLOWABLE LEVELS. MECH(GEN): NOT GENERALLY REQD (ING 12)
Other Protective Equipment:IMPERVIOUS CLOTHING SHOULD BE WORN TO
PREVENT REPEATED OR PROLONGED SKIN CONTACT WITH PRODUCT IN A LIQUID
STATE.
Work Hygienic Practices:WASH HANDS W/SOAP & WATER/A SKIN CLEANSER
BEFORE EAT, DRINK, SMOKING, OR USING TOILET FACILITIES. CONT LENSES
(ING 14)
Supplemental Safety and Health
EFTS OF OVEREXP: WATER BETWEEN APPLICATN GREATLY REDUCE TUMOR FORM.
THESE STUDIES DEMONSTRATE EFTIVNESS OF CLEANSING SKIN AFTER CONT.
POTNTL RISKS TO HUMANS CAN BE MINIMIZED BY OBSERVING GOOD WORK PRA
CTICES & PERSONAL HYGIENE PROC GENERALLY RECOM FOR PETROLEUM PROD.
EYES: ACUTE: MAY CAUSE MINOR TRANSIENT (ING 7)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>311F,>155C
Vapor Pres:<1@20C
Vapor Density:>1
Spec Gravity:1.589(H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:DARK WHITE COLOR, FAINT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS AND ACIDS.
Stability Condition to Avoid:FLAME, SPARK OR EXTREME HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTAMD ABSORB MATL/WASTE PROD MUST BE DISPOSED
OF I/A/W REGULATIONS IN RESOURCE CONSERVATION AND RECOVERY ACT &/OR
FEDERAL, STATE, LOCAL OR EPA REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BURKE-KRETE MORTAR POWDER, CM-0260
Preparer's Name:PETER FUQUA
CAGE:IO955
CAGE:IO955
CAGE:22108
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST;9495
Ingred Name:PORTLAND CEMENT
CAS:65997-15-1
RTECS #:VV8770000
OSHA PEL:50 MPPCF; Z-3
ACGIH TLV:10 MG/M3 TDUST; 9495
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9495
Ingred Name:VOLATILE ORGANIC COMPONENTS (COATING): 0. LB/GL
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: CEMENT DUST CAN CAUSE
INFLAMMATION OF THE LINING TISSUE OF THE NOSE AND INFLAMMATION OF
THE EYE. HYPERSENSITIVE INDIVIDUALS MAY DEVELOPE A RASH ON THE
SKIN. SKIN AND EYE CONTACT: WET CEMENT, EX PECIALLY AS AN (EFTS OF
OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC
MONOGRAPHS, SUPPLEMENT. VOL 7, PG 341, 1987: GROUP 2A. NTP 7TH
ANNUAL REPORT ON(SUPDAT)
Effects of Overexposure:HLTH HAZ: INGRED IN PLASTIC CONCRETE CAN DRY
THE SKIN & CAUSE ALKALI BURNS. CEMENT DUST CAN CAUSE IRRIT IN THE
EYES & UPPER RESP SYSTEM. SKIN ABSORPTION: MAY CAUSE IRRIT/RASH IN
SENSITIVE INDIVIDUALS. INGESTION: MAY IRRIT MOUTH,
ESOPHAGUS,STOMACH, ETC.
Medical Cond Aggravated by Exposure:HYPERSENSITIVE INDIVIDUALS MAY
DEVELOP A SKIN RASH.
======================= First Aid Measures =======================
First Aid:EYES: IRRIGATE EYES WITH WATER FOR AT LEAST 15 MINUTES AND
CONSULT A PHYSICIAN. SKIN: WASH EXPOSED AREA WITH PLENTY OF WATER
IMMEDIATELY. INHALATION: DUST CAN CAUSE INFLAMMATION OF THE UPPER
RESPIRATO RY TRACT, CONSULT PHYSICIAN. INGESTION:DO NOT INGEST,
CONSULT PHYSCIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP USING DRY METHODS THAT DO NOT
DISPERSE THE DUST INTO THE AIR. AVOID BREATHING THE DUST. EMERGENCY
PROCEDURES ARE NOT REQUIRED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PREVENT EYE AND SKIN CONTACT.
Other Precautions:AVOID HANDLING IN WINDY OR DUSTY CONDITIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE ADEQUATE VENTILATION WHEN USING THIS
PRODUCT. IF THE EXPOSURE LIMITS IN INGREDIENTS SECTION ARE EXCEEDED
A NIOSH/MSHA APPROVED MASK WITH ORGANIC CARTRIDGE MUST BE USED.
Ventilation:AVOID BREATHING DUST.
Other Protective Equipment:ANSI APPRVD EMER EYE WASH & DELUGE SHOWER .
IMPERVIOUS BOOTS AND CLOTHING TO PREVENT SKIN CONTACT.
Work Hygienic Practices:GOOD HOUSEKEEPING PROCEDURES SHOULD BE FOLLOWED
AT ALL TIMES.
Supplemental Safety and Health
EXPLAN OF CARCIN: CARCINOGENS, 1994: ANTICIPATED TO BE CARCINOGEN.
TO PREVENT EYE IRRITATION. (MFR)
================== Physical/Chemical Properties ==================
Spec Gravity:2.65 (H*2O = 1)
Solubility in Water:SLIGHT
Appearance and Odor:POWDER WITH NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE & LOCAL REGULATIONS . CAN BE TREATED AS COMMON WASTE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BLACK BLAST
CAGE:1B610
CAGE:1B610
============= Composition/Information on Ingredients =============
CALL WITH MFR).BLACK BLAST,FINES BLAST,ONE AND THE SAME.
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS AND SYMPTOMS OF
OVEREXPOSURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:IRRIT AND POSS ABRASION,DAMAGE TO OUTER
SURFACE OF EYE.SKIN:IRRIT & ABRASIVE ACTION MAY CAUSE
CUTS.INGESTION:NOT INTENDED FOR INGEST.MAY CAUSE GI
DISTURBANCES.VOMITING AND DIARRHEA.INHALATION:DUS T MAY CAUSE
RESPIRATORY TRACT IRRITATION.
Medical Cond Aggravated by Exposure:REPEATED OR PROLONGED BREATHING OF
PARTICLES OF RESPIRABLE SIZE MAY AGGRAVATE PRE-EXISTING MEDICAL
CONDITIONS:SPECIFICALLY BRONCHIAL HYPER-REACTIVITY AND CHRONIC
BRONCHIAL OR LUNG DISEASE.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH WATER,HOLDING LIDS AWAY FROM EYEBALL FOR AT
LEAST 15 MIN.SKIN:WASH WITH SOAP AND WATER.INGESTION:GIVE 1-3
GLASSES OF WATER OR MILK.INHALATION:REMOVE TO FRESH AIR.SUPPORT
BREATHING (GIV E O*2/ARTIFICIAL RESPIRATION) .
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
================== Accidental Release Measures ==================
Spill Release Procedures:WETTING WITH WATER WILL REDUCE AIRBORNE
DUST.SWEEP UP UNDER NORMAL CLEANUP PROCEDURES.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT CREATE UNNECESSARY AIRBORNE
DUST WHEN HANDLING.IN CONFINED AREAS,PROVIDE ADEQUATE VENTILATION.
EYE CONTACT.USE NIOSH OR MSHA APPROVED BREATHING EQUIPMENT FOR
PROLONGED EXPOSURE TO AIRBORNE DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW LEVEL OF CONCERN .
Other Protective Equipment:AS NEEDED HEARING PROTECTION AND CLOTHING AS
DESIRED BY USER.
Work Hygienic Practices:USE GOOD PERSONAL HYGIENE.WEAR REGULARLY
CLEANED WORK CLOTHING.
Supplemental Safety and Health
N/K
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:1300F,704C
Decomp Temp:Decomp Text:N/K
Spec Gravity:2.75 (WATER=1)
Solubility in Water:NOT SOLUBLE
Appearance and Odor:GRANULAR AND ANGULAR PARTICLES OF A SHINY BLACK
COLOR.NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .MATERIAL MAY BE DISPOSED OF AS
AN INERT SOLID IN AN APPROPRIATE SOLID WASTE LANDFILL IAW ABOVE
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SUPER QUADROLUBE GEAR LUBRICANT, 85W/140
CAGE:DO899
CAGE:77493
CAGE:DO899
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM HYDROCARBONS (MFR SUGGESTS TLV FOR PRODUCT OF 5
MG/CUM AS OIL MIST)
Ingred Name:ADDITIVES
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER & OBTAIN MED ATTN. INGEST:DO NOT INDUCE
VOMIT.OBTAIN MED. ATTN. SKIN:AVOID RPTD/PRLNG CNTCT W/SKIN.WASH
CONTAM AREAS W/SOAP & WATER.
===================== Fire Fighting Measures =====================
Flash Point:385F MIN COC
Extinguishing Media:CO*2,FOAM, DRY CHEMICAL
Fire Fighting Procedures:COOL EXPOS CONTAINERS W/WATER
Unusual Fire/Explosion Hazard:DO NOT STORE OR MIX W/STRONG OXIDANTS
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE SPILLS.TAKE UP SPILLED MATERIAL W/DRY
CHEMICAL ABSORBENT.PREVENT ENTRY INTO SEWERS &/OR WATER COURSES
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLSD.AVOID EXCESSIVE
HEAT OR DIRECT FLAME.
Other Precautions:AVOID CONTACT W/EYES.AVOID PRLNG/RPTD CNTCT W SKIN.
============= Exposure Controls/Personal Protection =============
Ventilation:ADEQUATE
Other Protective Equipment:LONG SLEEVES.MFR ALSO RECM NITRILE TY
Supplemental Safety and Health
SPECIFIC GRAVITY: 0.8871/0.8816. 5 GALLON CONTAINER SIZE.
================== Physical/Chemical Properties ==================
HCC:V6
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT AMBER LIQ W/ORGANIC ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS SUCH AS LIQ CHLORINE & CONC OXYGEN
Hazardous Decomposition Products:OXIDES OF CARBON
==================== Disposal Considerations ====================
Waste Disposal Methods:MFR RECM INCIN OR SANITARY LANDFILL DISPOSAL IAW
FED,STATE & LOCAL CODES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ROYCO 586M
Resp. Party Other MSDS Num.:750.005-1
CAGE:07950
Contract Num:SP0450-99-M-B272
CAGE:0WA27
Contract Num:SP0450-99-MB309
CAGE:0WA27
CAGE:07950
============= Composition/Information on Ingredients =============
Ingred Name:SEVERELY HYDROTREATED HEAVY NAPHTHENIC DISTILLATE
CAS:64742-52-5
Code:F
RTECS #:PY8035000
Minumum % Wt:65.
Maxumum % Wt:75.
Ingred Name:SEVERELY HYDROTREATED LIGHT NAPHTHENIC DISTILLATE
CAS:64742-53-6
Code:F
RTECS #:PY8036000
Minumum % Wt:25.
Maxumum % Wt:35.
Ingred Name:MINOR ADDITIVES
< Wt:6.
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT: NOT EXPECTED TO BE MORE
THAN MINIMALLY IRRITATING TO EYES. SKIN CONTACT: PROLONGED OR
REPEATED CONTACT MAY CAUSE VARIOUS DISORDERS SUCH AS DERMATITIS,
FOLLICULITIS OR OIL ACNE. INHALATION : INHALATION OF VAPORS
(GENERATED AT HIGH TEMPERATURES ONLY) MILDLY IRRITATING TO THE
NOSE, THROAT AND RESPIRATORY TRACT. INGESTED: LUBRICATING OILS ARE
GENERALLY CONSIDERED TO BE NO MORE THAN SLIGHTL Y TOXIC IF
INGESTED.
Explanation of Carcinogenicity:THIS PRODUCT DOES NOT CONTAIN ANY
CARCINOGEN AS IDENTIFIED BY IARC, NTP OR OSHA.
Effects of Overexposure:IRRITATION AS PREVIOUSLY NOTES.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN & RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYES-FLUSH WITH WATER. IF IRRITATION OCCURS, GET MEDICAL
ATTENTION. SKIN CONTACT-REMOVE CONTAMIANTED COTHES/SHOES & WIPE
EXCESS FROM SKIN. FLUSH SKIN WITH WATER. FOLLOW BY WASHING WITH
SOAP & WATER. I F IRRITATION OCCURS, GET MEDICAL ATTENTION.
INGESTION: DO NOT INDUCE VOMITING! IN GENERAL NO TREATMENT IS
NECESSARY UNLESS LARGE QUANTITIES OF PRODUCT ARE INGESTED. HOWEVER,
GET MEDICAL ADVICE.
===================== Fire Fighting Measures =====================
Flash Point:>93.3C, 200.F
Lower Limits:N/AV
Upper Limits:N/AV
Extinguishing Media:USE WATER, FOG, FOAM, DRY CHEMICAL OR CARBON
DIOXIDE (CO2). DO NOT USE DIRECT STREAM OF WATER.PRODUCT WILL
FLOAT AND CAN BE REIGNITED ON SURFACE OF WATER.
Fire Fighting Procedures:MATERAIL WILL NOT BURN UNLESS PRHEATED. DO
NOT ENTER CONFIGNED FIRE SPACE WITHOUT FULL BUNKER GEAR HELMET WITH
POSITIVE PRESSURE NIOSH APPROVED SELF-CONTAINED BREATHING
APPARATUS.COOL FIRE EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:SULFUR OXIDES AND HYDROGEN SULFIDE, BOTH
OF WHICH ARE TOXIC, MAY BE RELEASED UPON COMBUSTION.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILLS: TAKE UP WITH AN ABSORBENT
MATERIAL & DISPOSE OF PROPERLY. LARGE SPILL: WEAR RESPIRATOR &
APPROPRIATE PROTECTIVE CLOTHING. SHUT OFF SOURCE IF SAFE TO DO SO.
DIKE & CONTAIN. REMOVE WITH V ACUUM TRUCK OR PUMP TO
STORAGE/SALVAGE VESSELS. SOAK UP RESIDUE WITH AN ABSORBENT SUCH AS
CLAY, SAND OR OTHER SUITABLE MATERIAL; DISPOSE OF PROPERLY. FLUSH
WITH WATER TO REMOVE TRACE RESIDUE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP AWAY FROM OPEN FLAMES AND HIGH
TEMPERATURES.
Other Precautions:WASH WITH SOAP & WATER BEFORE EATING, DRINKING,
SMOKING OR USING TOILET FACILITIES. LAUNDER CONTAMINATED CLOTHES
BEFORE REUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURE MAY OR DOES EXCEED OCCUPTIONAL
EXPOSURE LIMITS (SEC. IV) USE A NIOSH-APPROVED RESPIRATOR TO
PREVENT OVEREXPOSURE. IN ACCORD WITH 28 CFR 1910.134 USE EITHER AN
ATMOSPHERE-SUPPLYING RESPIRA TOR OR AN AIR-PURIFYING RESPIRATIOR
FORORGANIC VAPORS AND PARTICULATES.
Ventilation:STORE IN A COOL, DRY PLACE WITH ADEQUATE VENTILATION.
MINIMIZE CONTACT.
Other Protective Equipment:WEAR RESPIRATOR AND PROTECTIVE CLOTHING AS
APPROPRIATE.
Work Hygienic Practices:WASH WITH SOAP & WATER BEFORE EATING, DRINKING,
SMOKING OR USING TOILET FACILITIES. LAUNDER CONTAMINATED CLOTHES
BEFORE REUSE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:NOT AVAILABLE
Melt/Freeze Pt:M.P/F.P Text:NOT AVAILABLE
Vapor Pres:NOT AVAILABLE
Spec Gravity:APPROX. 0.85
Viscosity:CS (100F): 70
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER OIL: MODERATE SULFUR ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID HEAT, FLAME AND CONTACT WTIH STRONG
OXIDIZING AGENTS.
Hazardous Decomposition Products:CARBON MONOXIDE, SULFUR OXIDES AND
UNIDENTIFIED ORGANIC MATERIALS MAY BE FORMED DURING COMBUSTION.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:NONE SPECIFIED BY MANUFACTURER.
===================== Ecological Information =====================
Ecological:UNDER EPA-CWA, THIS PRODUCT IS CLASSIFIED S AN OIL UNDER
SECTION 311. SPILLS INTO OR LEADING TO SURFACE WATERS THAT CAUSE A
SHEEN MUST BE REPORTED TO THE NATIONAL RESPONSE CENTER,
800-424-8802.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE IN AN APPROPRIATE DISPOSAL FACILITY IN
COMPLIANCE WITH LOCAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:NOT HAZARDOUS BY DOT REGULATIONS.
===================== Regulatory Information =====================
SARA Title III Information:NONE SPECIFIED BY MANUFACTURER.
Federal Regulatory Information:THE COMPONENTS OF THIS PRODUCT ARE
LISTED ON THE EPA/TSCA INVENTORY OF CHEMICAL SUBSTANCES.
State Regulatory Information:NONE SPECIFIED BY MANUFACTURER.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FW
CAGE:HO461
CAGE:91174
CAGE:HO461
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM OXIDE (2:3) (SARA 313)
CAS:1344-28-1
RTECS #:BD1200000
Fraction by Wt: 96-100%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 0-4%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: PARTICULATE MAY CAUSE
SLIGHT TO MODERATE IRRITATION. ABRASIVE ACTION OF DUST CAN DAMGE
EYES. SKIN: NO EVIDENCE OF ADVERSE EFFECTS EXPECTED. INHALATION:
INHALATION OF AIRBORNE PARTICULATEMAY CAUSE SLIGHT TO MODERATE
IRRITATIONOF MUCOUS MEMBRANES. CHRONIC: NONE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:IRRITATION, SHORTNESS OF BREATH, DECREASED
CHEST EXPANSION, DRY COUGH, FATIQUE.
Medical Cond Aggravated by Exposure:INDIVIDUALS W/LUNG DISORDERS SHOULD
NOT BE EXPOSED TO CONDITIONS WHERE LARGE AIRBORNE QUANTITIES OF
NUISANCE DUST EXISTS W/OUT PRECAUTIONS TAKEN TO ALLEVIATE
AGGRAVATED PREEXISTING MEDICAL CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHAL:IMMED REMOVE TO FRESH AIR & SEEK MED ATTN. EYES:IMMED
FLUSH W/LGE AMTS OF RUNNING WATER FOR AT LEAST 15 MIN. IF SYMPS
PERSIST, SEEK MED ATTN. SKIN:IF DUST GETS ON SKIN, WASH CONTAM AREA
W/SOAP & WATER. REMOVE & WASH CONTAM CLTHG. IF RASH, IRRIT/OTHER
SYMPS PERSIST, SEEK MED ATTN. INGEST:LEAVE DECISION TO INDUCE VOMIT
FOR MD, SINCE PARTICLES MAY BE ASPIRATED INTO LUNGS. SEEK IMMED MED
ATTN.
===================== Fire Fighting Measures =====================
Extinguishing Media:AS APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:AS APPROPRIATE FOR SURROUNDING FIRE. WEAR
NIOSH APPROVED SCBA & FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THIS ABRASIVE PRODUCT IS NON-COMBUSTIBLE
AND DOES NOT POSE FIRE OR EXPLOSION HAZARD, AND WILL NOT INITIATE
OR CONTRIBUTE TO THE INTENSITY OF A FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP USING METHS WHICH AVOID DUST
GENERATION. IF VACUUM IS USED, EXHST AIR SHOULD BE FILTERED BY
HIGH-EFFICIENCY PARTICULATE AIR (HEPA) FILTER. COMPRESSED AIR
SHOULD NOT BE USED TO CLEAN UP SPILLS . DURING CLEAN UP, SKIN & EYE
CONT & (SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP PRODUCTS IN CONTAINERS. HANDLE IN
SUCH A WAY TO MINIMIZE FROM BECOMING DISPERSED IN THE WORK
ENVIRONMENT.
Other Precautions:STORE IN CONTAINERS INDEFINITELY WITH NO RISK OF
HEALTH HAZARD. UTILIZE NIOSH APPROVED DUST RESPIRATOR WHEN ACUTE
DUSTINESS HAS OCCURRED IN WORK ENVIRONMENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPRVD RESP IF AIRBORNE CONTAMINANT
CONC EXCEEDS APPLIC PEL/TLV, OR OTHER INDUSTRY STDS/GUIDELINES ON
EXPOS. IF RESPPROT IS REQUIRED, ALL APPROP REQS AS SET FORTH IN 29
CFR 1910.134 MUST BE MET.
Ventilation:USE LOCAL &/GENERAL DILUTION VENTILATION, AS NEEDED, TO
REDUCE EMPLOYEE EXPOSURE TO BELOW APPLICABLE PEL/TLV.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH & DELUGE
SHOWER . CLOTHING WHICH MINIMIZES SKIN EXPOSURE TO ABRASIVE DUST.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPILL PROC: INHAL OF DUST SHOULD BE AVOIDED AS MUCH AS POSS. WHEN NEC,
WEAR APPROP PERS PROT EQUIP DURING CLEAN UP OPERATIONS. PLACE MATL
INTO CLEAN DRY CONTR W/CLEAN SHOVEL, * COVER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:6332F,3500C
Melt/Freeze Pt:M.P/F.P Text:3632F,2000C
Spec Gravity:3.97 (H*20=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE AND/OR BROWN GRANULAR OR FINE POWDER;NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NOT APPLICABLE.
Stability Condition to Avoid:CONTACT WITH INCOMPATIBLE MATERIALS.
Hazardous Decomposition Products:NOT APPLICABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY WITH FEDERAL, STATE AND LOCAL REGULATIONS
REGARDING REPORTING OF SPILLS AND DISPOSAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:262X LIGHTWEIGHT BODY FILLER
Preparer's Name:S ABDUL RAZZAK
CAGE:16522
CAGE:16522
============= Composition/Information on Ingredients =============
Ingred Name:DIETHYLENE GLYCOL, MALEIC ANHYDRIDE, PHTHALIC ANHYDRIDE
POLYMER*97-1*
CAS:26123-45-5
Fraction by Wt: <35%
Ingred Name:STYRENE, STYRENE MONOMER (SUSPECTED ANIMAL/HUMAN
CARCINOGEN BY IARC GROUP 2B) *97-1*
CAS:100-42-5
RTECS #:WL3675000
Fraction by Wt: <18%
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE (SUSP ANIMAL CARC BY IARC; NTP)* 97-1 *
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: <50%
OSHA PEL:2 MG/CUM (RESP DUST)
ACGIH TLV:2 MG/CUM (RESP DUST)
Ingred Name:SODA LIME BOROSILICATE GLASS (AMORPHOUS SILICATE)
Fraction by Wt: <50%
Ingred Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
CARCINOGEN, IARC GROUP 3)*97-1*
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: <50%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:VOLATILE ORGANIC CONTENT: MATERIAL 216 G/L
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: UPPER RESPIRATORY
IRRITATION. EYES: IRRITATION. SKIN: IRRITATION & DERMATITIS. IF
ECZEMATOUS DEVELOPS, MOST OFTEN OCCURS ON THE BACK OF HANDS, WRISTS
& FOREARMS.
Explanation of Carcinogenicity:STYRENE IS A SUSPECTED 2B ANIMAL
CARCINOGEN BY IARC.
Effects of Overexposure:IRRITATION, DRUGGED, SLEEPY, UNCONSCIOUSNESS,
RASH.
Medical Cond Aggravated by Exposure:RESPIRATORY CONDITIONS, ASTHMA,
CHRONIC BRONCHITIS, EMPHYSEMA.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER. SKIN: WASH THOROUGHLY W/SOAP &
WATER. INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED.
INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES .
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:(SEE SUPP)
Lower Limits:1.1
Upper Limits:6.1
Extinguishing Media:CO2, DRY CHEMICAL (SMALL FIRES), FOAM & WATER FOG
(LARGE FIRES).
Fire Fighting Procedures:VENT SMOKE & USE GAS MASK/REMOTE AIR SUPPLY.
WEAR A MSHA/NIOSH APPROVED SCBA W/PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:DENSE SMOKE SERIOUSLY LIMITS VISIBILITY.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION. INCREASE
VENTILATION TO MAXIMIZE VAPOR DISPERSAL. LARGE SPILL: DIKE TO
PREVENT RUNOFF INTO SEWERS/WATERWAYS. SHOVEL/WIPE. SWEEP/CLEAN
W/INERT MATERIAL SUCH AS SAND, VERMICU LITE & PLACE IN CLOSED
CONTAINER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY AREA. DON'T STORE
IN DIRECT SUNLIGHT. BOND/GROUND CONTAINERS FOR TRANSFER TO PREVENT
STATIC SPARKS. AVOID CONTACT W/SKIN & EYES.
Other Precautions:STYRENE VAPORS ARE UNINHIBITED & MAY CAUSE BLOCKAGE
OF VENTILATION VENTS DUE TO POLYMERIZATION. PERIODIC INSPECTION MAY
BE NECESSARY TO PREVENT BLOCKAGE. AVOID IMPROPER ADDITION OF
PROMOTERS & OXIDIZI NG AGENTS. AVOID ELECTRICAL EQUIPMENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH/MSHA APPROVED ORGANIC VAPOR/DUST
RESPIRATOR.
Ventilation:LOCAL EXHAUST: CONTROL THE EMISSION OF AIR CONTAMINANTS.
GENERAL: ASSIST W/THE REDUCTION OF AIR CONTAMINANTS.
Other Protective Equipment:SAFETY SHOWERS & EYE WASH STATIONS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. CLEAN HANDS W/SOAP & WATER AFTER EVERY USAGE.
Supplemental Safety and Health
INFORMATION IS FOR STYRENE: FLASH POINT 90F (TCC); BOILING POINT 293F;
VAPOR DENSITY 3.6.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:(SEE SUPP)
Vapor Density:(SEE SUPP)
Spec Gravity:1.05-1.35
Evaporation Rate & Reference:LESS THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE PASTE W/STYRENE ODOR.
Percent Volatiles by Volume:18%/WT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, PEROXIDES & OTHER OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, DIRECT
SUNLIGHT/OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:CO, CO2, LOW MOLECULAR WEIGHT
HYDROCARBONS & ORGANIC ACIDS.
Conditions to Avoid Polymerization:UNREGULATED CONTACT W/ORGANIC
PEROXIDES, EXPOSURE TO HEAT, OPEN FLAME, & STORAGE >100F.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AS SOLID WASTE IAW/FEDERAL, STATE &
LOCAL REGULATIONS. IF DISCARDED, THIS MATERIAL & CONTAINERS ARE
CONSIDERED RCRA HAZARDOUS WASTES BASED ON THE CHARACTERISTIC OF
IGNITABILITY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TERG-O-CIDE 236
CAGE:GO984
CAGE:53798
CAGE:GO984
============= Composition/Information on Ingredients =============
Ingred Name:DIDECYL-DIMETHYL AMMONIUM CHLORIDE
CAS:7173-51-5
RTECS #:BP6560000
Fraction by Wt: 4.5%
Ingred Name:TETRASODIUM EDTA
CAS:64-02-8
RTECS #:AH5075000
Fraction by Wt: 2.0%
Ingred Name:SODIUM CARBONATE
CAS:497-19-8
RTECS #:VZ4050000
Fraction by Wt: 1.0%
Ingred Name:SODIUM METASILICATE
CAS:6834-92-0
RTECS #:VV9275000
Fraction by Wt: 0.5%
Ingred Name:NONIONIC DETERGENT
Fraction by Wt: 92%
===================== Hazards Identification =====================
Effects of Overexposure:SINGLE SHORT TERM EXPOSURE: NO EFFECT. LONG
TERM REPEATED CONTACT: POSS DRY SKIN.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/ COLD WATER FOR AT LEAST 15 MIN; CALL MD. SKIN:
FLUSH W/WATER.
===================== Fire Fighting Measures =====================
Flash Point:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH W/COLD WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE BELOW FREEZING
TEMPERATURES.
Other Precautions:AVOID SKIN CONTACT. USE AS DIRECTED ON LABEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE (MFR)
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:218F;103C
Spec Gravity:1.06
Solubility in Water:COMPLETE
Appearance and Odor:YELLOW LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IAW FEDERAL, STATE & LOCAL CODES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ERUSTICATOR, 943613
Kit Part:Y
CAGE:0DAC4
CAGE:0DAC4
CAGE:85884
============= Composition/Information on Ingredients =============
Ingred Name:HYDROFLUORIC ACID (SARA 302/313) (CERCLA)
CAS:7664-39-3
RTECS #:MW7875000
Fraction by Wt: 10-15%
OSHA PEL:3 PPM (F)
ACGIH TLV:C 3 PPM (F)
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:AMMONIUM HYDROGEN FLUORIDE; (AMMONIUM BIFLUORIDE) (CERCLA)
CAS:1341-49-7
RTECS #:BQ9200000
Fraction by Wt: 25-30%
OSHA PEL:2.5 MG (F)/M3
ACGIH TLV:2.5 MG (F)/M3
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DANGER-POISON. ACUTE: SKIN/EYES:
CAUSES SEV CHEM BURNS. EYE CONT MAY CAUSE BLINDNESS. HARMFUL CONT
MAY NOT CAUSE IMMED PAIN. (IMMED WATER FLUSHING IS VITAL IN CASE OF
EYE CONT.) INGEST: HARMFUL/FATAL. CAUSES CHEM BURNS OF MOUTH,
THROAT & STOM. INHAL: DAMAGES AIRWAYS & LUNGS, DEPENDING UPON AMT &
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: DURATION OF EXPOS. EFTS CAN VARY FROM
SLIGHT IRRIT TO BRONCHITIS/PNEUMONIA.
Medical Cond Aggravated by Exposure:PEOPLE WITH ASTHMA OR OTHER LUNG
PROBLEMS MAY BE MORE AFFECTED.
======================= First Aid Measures =======================
First Aid:EYES: IMMED FLUSH W/PLENTY OF COOL RUNNING WATER. REMOVE CONT
LENSES. CONTINUE FLUSHING FOR AT LEAST 15 MIN, HOLDING EYELIDS
APART TO ENSURE RINSING OF ENTIRE EYE. SKIN: IMMED FLUSH W/PLENTY
OF COOL R UNNING WATER FOR AT LEAST 15 MIN WHILE REMOVING CONTAM
CLTHG & SHOES. WASH CLTHG BEFORE REUSE. INGEST: RINSE MOUTH AT
ONCE; THEN DRINK 1-2 LGE GLASSES OF WATER/MILK. DO NOT INDUCE
VOMIT. (SUP DAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:PRODUCT DOES NOT SUPPORT COMBUSTION. USE MEDIA
SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:IN CASE OF FIRE, HIGHLY CORROSIVE
HYDROGEN FLUORIDE (HF) FUMES MAY BE EMITTED.
================== Accidental Release Measures ==================
Spill Release Procedures:PREVENT SKIN CONTACT. DIKE OR DAM LARGE
SPILLS. PUMP TO CONTAINERS OR SOAK UP ON INERT ABSORBENT. FLUSH
RESIDUE TO SANITARY SEWER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID BREATHING MISTS OR VAPORS OF THIS PRODUCT.
USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: NEVER GIVE ANYTHING BY MOUTH TO AN UNCON PERSON. INHAL:
IMMED MOVE TO FRESH AIR. IMMED CALL POISON CTL CTR, MD/ECOLAB 24-HR
MED EMER NUMBER (1-800-328-0026). EYE PROT: & FULL LENGTH FA
CESHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>180F,>82C
Spec Gravity:1.10-1.20
pH:<1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID WITH SHARP ACID ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CAN REACT VIOLENTLY WITH ALKALINE MATERIALS OR METALS. DO NOT MIX WITH
CHLORINATED DETERGENTS OR SANITIZERS.
Stability Condition to Avoid:MIX ONLY WITH WATER.
Hazardous Decomposition Products:WILL CAUSE HAZARDOUS VAPORS IF MIXED
WITH CHLORINATED DETERGENT OR SANITIZERS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT STATE AND LOCAL AUTHORITIES FOR
RESTRICTIONS ON DISPOSAL OF CHEMICAL WASTE. UNUSED PRODUCT AS A
WASTE IS CORROSIVE (D002) BY RCRA CRITERIA. DISPOSE OF IN
ACCORDANCE WITH LOCAL, STATE AND FEDER AL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ADVANCE HYBRID IONOMER CEMENT LIQUID
Kit Part:Y
CAGE:11107
CAGE:11107
============= Composition/Information on Ingredients =============
Ingred Name:METHACRYLATE MONOMER
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MAY CAUSE IRRITATION & POSSIBLE
CORNEAL DAMAGE. INDIVIDUALS SUSCEPTABLE TO ACRYLICS MAY DEVELOP
ALLERGIC RESPONSE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, NAUSEA
Medical Cond Aggravated by Exposure:KNOWN SENSITIVITY TO ACRYLATES.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/COPIOUS AMOUNTS OF WATER FOR 15 MINS.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR MSHA/NIOSH APPROVED, PRESSURE DEMAND,
SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. DIKE & ABSORB
W/INERT MATERIALS; SAND, SODA ASH, VERMICULITE & TRANSFER TO AN
APPROPRIATE CONTAINER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT AMBIENT TEMPERATURE OUT OF
DIRECT SUNLIGHT & HEAT. KEEP AWAY FROM FLAME & SPARKS.
Other Precautions:KEEP AWAY FROM FOOD & BEVERAGES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED FOR INTENDED USE OF THIS PRODUCT.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:APRON
Work Hygienic Practices:OBSERVE NORMAL CARE WHEN WORKING W/CHEMICALS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:>1
Solubility in Water:PARTIAL
Appearance and Odor:THIN, LIGHT YELLOW W/FAINT ACIDIC ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS, PEROXIDES
Stability Condition to Avoid:HEAT & LIGHT
Hazardous Decomposition Products:ACID FUME, CO, CO2
Conditions to Avoid Polymerization:INTENSE LIGHT, PEROXIDE & PROLONGED
STORAGE >100.4F.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:5554 BARE WIRE ALUMINUM ALLOY
CAGE:0ACE2
CAGE:0ACE2
============= Composition/Information on Ingredients =============
Ingred Name:ZINC OXIDE *95-4*
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: 0.25%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM FUME
Ingred Name:THALLIUM
CAS:7440-28-0
RTECS #:XG3425000
Fraction by Wt: 0-0.2%
OSHA PEL:0.1 MG/CUM
ACGIH TLV:0.1 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ALUMINUM (POWDER) *95-4*
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 94.6%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:AMORPHOUS FUSED SILICA, SILICON DIOXIDE, QUARTZ, SILICON
(SUSPECTED HUMAN CARCINOGEN BY IARC - GROUP 2A) *95-4*
CAS:60676-86-0
RTECS #:VV7328000
Fraction by Wt: 0.25%
Other REC Limits:30 MG/CUM TOTAL DUST
ACGIH TLV:0.1 MG/CUM (RESP) IC
Ingred Name:RED IRON OXIDE/IRON (III) OXIDE/FERRIC OXIDE/YELLOW FERRIC
OXIDE/YELLOW IRON OXIDE/IRON OXIDE PIGMENT
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 0.4%
OSHA PEL:10 MG/CUM
ACGIH TLV:5 MG/CUM (FE)
Ingred Name:COPPER (DUST & MIST), BRONZE POWDER *95-4*
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 0.1%
Other REC Limits:1 MG(CU)/M3 (DUST)
OSHA PEL:0.1 MG(CU)/M3 (FUME)
ACGIH TLV:0.2 MG/M3 (FUME)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:MANGANESE, MN COMPOUNDS
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 0.5-1%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM (DUST)
Ingred Name:MAGNESIUM OXIDE, MAGNESIA
CAS:1309-48-4
RTECS #:OM3850000
Fraction by Wt: 2.4-3%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM
Ingred Name:CHROMIUM METAL, CHROMIUM, CHROME (KNOWN CARCINOGEN BY NTP;
IARC CARC - GROUP 3) *95-4*
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 0-0.2%
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SHORT TERM EXPOSURE TO WELDING FUME
MAY CAUSE IRRITATION OF THE THROAT. LONG TERM EXPOSURE TO WELDING
FUME, GASES/DUST MAY CONTRIBUTE TO PULMONARY
IRRITATION/PNEUMOCONIOSIS. LONG TERM EXPOSURE TO IRON FUME MAY
PRODUCE SIDEROSIS. BURNS FROMELECTROMAGNETIC RADIATION.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:SHORT TERM EXPOSURE TO WELDING FUME:
DISCOMFORT, DIZZINESS, NAUSEA, DRYNESS, IRRITATION.
Medical Cond Aggravated by Exposure:IMPAIRED PULMONARY
FUNCTION/ILLNESS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR IF NEEDED. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONCOMBUSTIBLE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:METAL POWDER FIRE: USE DRY SAND, DRY GRAPHITE/OTHER
CLASS D FIRE EXTINGUISHING POWDER.
Fire Fighting Procedures:IF MATERIAL IS REDUCED TO POWDER FORM, CAUTION
MUST BE USED TO PREVENT FIRE/EXPLOSION.
Unusual Fire/Explosion Hazard:CONTACT W/MINERAL ACIDS & OXIDIZING
AGENTS MAY GENERATE HYDROGEN GAS WHICH MAY BE AN EXPLOSION HAZARD.
======================Handling and Storage ======================
Handling and Storage Precautions:WEAR APPROPRIATE EQUIPMENT TO PREVENT
INJURY FROM RADIATION/SPARKS/ELECTRIC SHOCK. TRAIN THE EMPLOYEE TO
KEEP HEAD OUT OFUMES.
Other Precautions:USE EXHAUST SYSTEM TO CLEAR WELDING FUMES. MAKE SURE
THAT INHALED AIR DOESN'T CONTAIN FUME CONSTITUENTS ABOVE
PERMISSABLE LEVELS. TRAIN WELDER NOT TO TOUCH LIVE ELECTRICAL PARTS
& INSULATE HIMSELF FRO M WORK & GROUND.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRABLE FUME RESPIRATOR/AIR SUPPLIED
RESPIRATOR WHEN WELDING, BRAZING/SOLDERING IN CONFINED SPACES/WHERE
LOCAL EXHAUST/VENTILATION DOESN'T KEEP EXPOSURE BELOW PELS,
TLVS/STELS.
Ventilation:USE LOCAL EXHAUST AT THE ARC/FLAME TO KEEP FUMES & GASES
BELOW PELS, TLVS/STELS IN WORKERS BREATHING ZONE/GENERAL AREA.
ARM PROTECTORS/APRONS/HATS/SHOULDER PROTECTION/DARK SUBSTANTIAL
CLOTHING.
Work Hygienic Practices:WELDER'S SHOULDN'T WEAR SHORT SLEEVES
SHIRTS/SHORT PANTS/CUTOFFS.
Supplemental Safety and Health
PRODUCT IS NON-HAZARDOUS UNTIL USED AS IN WELDING PURPOSE. THE
COMPOSITION & QUANTITY OF FUMES/GASES DEPENDS ON METAL BEING
WELDED, PROCESS, PROCEDURES, ELECTRODES USED, COATING, POSITION OF
WELDERS H EAD W/RESPECT TO THE FUME PLUME & AS WELL AS THE PRESENCE
OF CONTAMINANTS IN THE ATMOSPHERE.
================== Physical/Chemical Properties ==================
Appearance and Odor:SOLID WIRE/ROD, GREY TO SILVER IN COLOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONTACT W/MINERAL ACIDS & OXIDIZING AGENTS MAY GENERATE HYDROGEN GAS.
Stability Condition to Avoid:(SEE SUPP)
Hazardous Decomposition Products:VARIOUS ELEMENTAL METALS & METAL
OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSABLE
CONTAINER/LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER
IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:P-22 DEVELOPER ADDITIVE
CAGE:64145
CAGE:64145
============= Composition/Information on Ingredients =============
Ingred Name:ANIONIC STILBENE DISULFONIC ACID DERIVATIVE
CAS:2895-61-0
Fraction by Wt: <5%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: <97%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT IS CONSIDERED BY MFR TO BE
NON-IRRITATING. IT IS CONSIDERED A VERY LOW HAZARD FOR NORMAL
INDUSTRIAL HANDLING.
Explanation of Carcinogenicity:THIS PRODUCT CONTAINS NO INGREDIENT
LISTED AS CARCINOGEN BY IARC,NTP, OR OSHA.
Effects of Overexposure:EYE/SKIN: NON-IRRITATING. INHALED:UNLIKELY
EXPOSURE ROUTE, ALSO CONSIDERED NON-IRRITATING. INGESTED:MFR
CLAIMS VERY LOW POTENTIAL FOR TOXICITY. (NEARLY NON-TOXIC.)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH WITH WATERSKIN:REMOVE CONTAMINATED CLOTHING AND
LAUNDER BEFORE REUSE. WASH SKIN WITH SOAP AND WATER. INHALED:
REMOVE TO FRESH AIR. INGESTED:IF CONSCIOUS,GIVE 1-2 GLASSES OF
WATER (NOTHI NG BY MOUTH IF UNCONSCIOUS.) AND GET IMMEDIATE MEDICAL
CARE. IF ANY IRRITATION OCCURS, GET MEDICAL CARE.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:USE MEDIA APPROPRIATE FOR SOURCE OF FIRE.G.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER AS LIQUID OR ADSORB WITH
CLOTH,PAPER,OTHER INERT MATERIAL.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY,WELL VENTILATED
AREA.
Other Precautions:READ LABEL THEN FOLLOW INSTRUCTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:NORMAL VENTILATION IS USUALLY SUFFICIENT. LOCAL EXHAUST
UNNECESSARY.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER. USE APRON
AND FACE SHIELD WHEN MIXING LIQUIDS OR IF SPLASHING IS LIKELY.
Work Hygienic Practices:USE GOOD CHEMICAL HYGIENE PRACTICE. AVOID
UNNECESSARY CONTACT.
Supplemental Safety and Health
ILFORD STOCK NUMBER OC8351010 IS 1 L. P-22 CHEMISTRY MAY BE SOLD AS
"CIBACHROME" OR "CIBACOPY". ALSO SEE ADD.DATA.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:<32F,<0C
Vapor Pres:AS WATER
Vapor Density:AS WATER
Spec Gravity:CA. 1
pH:9-9.5
Evaporation Rate & Reference:AS WATER
Solubility in Water:COMPLETE
Appearance and Odor:YELLOW/GREEN LIQUID, NO ODOR
Percent Volatiles by Volume:99.5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W FEDERAL,STATE,LOCAL REGULATIONS.
MFR SUGGESTS FLUSH TO SEWER IF PERMITTED. MFR CLAIMS PRODUCT TO BE
BIODEGRADABLE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LOW VOC SG GRAY EPOXY PART A C26250
Kit Part:Y
CAGE:EO432
CAGE:EO432
CAGE:72988
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ISOAMYL KETONE
CAS:110-12-3
RTECS #:MP3850000
Fraction by Wt: 3%
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9293
Ingred Name:METHYL ISOBUTYL KETONE (SARA III)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 7%
OSHA PEL:100 PPM/75 STEL
ACGIH TLV:50 PPM/75 STEL; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 2%
Other REC Limits:100 PPM (MFR)
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:N-BUTYL ALCOHOL (SARA III)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 2%
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:FATTY ACID AMIDES; (POLYAMIDE RESIN). LD50:(ORAL) 4 G/KG.
CAS:68910-93-0
Fraction by Wt: 11%
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 21%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:SILICONE DIOXIDE; (DIATOMACEOUS SILICA)
CAS:68855-54-9
Fraction by Wt: 2%
Other REC Limits:0.08 MG/M3 (MFR)
OSHA PEL:6 MG/M3 (TDUST)
ACGIH TLV:10 MG/M3 (TDUST)
Ingred Name:BARIUM SULFATE
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: 4%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 45%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 3%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYE/SKIN:IRRITATION. POSSIBLE
SENSITIZER. INHAL:MAY CAUSE DIZZINESS, NAUSEA & POSSIBLE
UNCONSCIOUSNESS. PROLONGED &/OR EXCESSIVE EXPOSURE TO DUST FROM
SANDING, GRINDING OR BLASTING MAY CAUSE LUNG DISO RDERS. OPERATORS
SHOULD WEAR APPROPRIATE PROTECTIVE GEAR DURING SUCH OPERATIONS.
Explanation of Carcinogenicity:SILICA, CRYSTALLINE: CLASS 2A (IARC)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. APPLY ARTIFICIAL RESPIRATION IF
NEEDED. SKIN:WASH W/SOAP & WATER. EYE:FLUSH W/WATER FOR AT LEAST 15
MINUTES. CALL MD. INGEST:CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point:20.0F,-6.7C
Lower Limits:1.0
Extinguishing Media:FOAM, CO*2, OR DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:WATER NOT A SUITABLE EXTINGUISHING
MEDIUM.
================== Accidental Release Measures ==================
Spill Release Procedures:ENSURE ADEQUATE VENTILATION. REMOVE IGNITION
SOURCES. ABSORB SMALL SPILLS ON DRY ABSORPTION MATERIALS. USE
SPARK-PROOF SCOOP FOR LARGER SPILLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM OPEN IGNITION SOURCES. AVOID
EXCESS HEAT.
Other Precautions:NPCA/HMIS RATING 3,3.0.H. PRODUCT CONTAINS CHEMICALS
SUBJECT TO THE REPORTING REQUIREMENTS OF SARA TITLE III, SEC 313,
40 CFR 372.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED VAPOR CARTRIDGE MASK OR
AIR-SUPPLIED HOOD.
Ventilation:SUFFICIENT TO ENSURE LEL NOT ACHIEVED.
Other Protective Equipment:PROTECT SKIN W/CLOTHING OR BARRIER CREAM.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:174F,79C
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:36
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Hazardous Decomposition Products:CARBON MONOXIDE & CARBON DIOXIDE ON
COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AS HAZARDOUS WASTE PER FEDERAL, STATE
& LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CAUSTIC SODA FLAKE
CAGE:5A188
CAGE:5A188
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 100%.
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:EYES:CAUSE SEVERE DAMAGE.SKIN:CAUSES BURNS,DEEP
ULCERATION.BREATHING:SEVERE DAMAGE TO MUCOUS MEMBRS
======================= First Aid Measures =======================
First Aid:INHAL:RMV TO FRESH AIR. IF NOT BRTHNG GIVE CPR; IF BRTHNG
DIFF GIVE OXYGEN. EYE:IMMED FLUSH W/PLENTY OF WATER. SKIN:WASH
W/SOAP & WATER. RMV CONTAM CLTHG & SHOES. INGEST:DO NOT INDUCE
VOMIT.NOTHG BY M OUTH IF UNCONSC.GET MEDICAL ATTN.
===================== Fire Fighting Measures =====================
Extinguishing Media:NOT COMBUSTIBLE BUT CONTACT W/WATER MAY GENERATE
HEAT.
Fire Fighting Procedures:FLOOD W/WATER, USING CARE NOT TO SPLATTER OR
SPLASH MATERIAL
Unusual Fire/Explosion Hazard:REACT W/METALS SUCH AS AL,ZN,MG,CU TO
RELEASE EXPLOSIVE AMTS OF HYDROGEN GAS.
================== Accidental Release Measures ==================
Spill Release Procedures:IMMED SWEEP UP, RMV & PLACE IN CLOSED
CONTAINER. FLUSH AREA W/WATER. USE DILUTE ACETIC ACID TO NEUTRALIZE
FINAL TRACES.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT AGAINST PHYSICAL DAMAGE, STORE
IN DRY PLACE; PROTECT AGAINST MOISTURE & WATER. SEPARATE FM
ACIDS,METALS,EXPLOSIVES,ORGANIC PEROXIDES, ETC.
Other Precautions:TOXIC. A SEVERE EYE HAZARD; SOLID OR CONCENTRATED
SOLUTION DESTROYS TISSUE ON CONTACT. EMPTIED CONTAINERS W/RESIDUE
ARE HAZARDOUS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MESA JOINTLY APPD SELF-CONTAINED BREATHING
APPARATUS W/FULL PC
Ventilation:MECHANICAL &/OR LOCAL EXHAUST VENTILATION TO MAINTAIN <
TLV.
Other Protective Equipment:SAFETY GLASSES,FACE SHIELD.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:B1
Boiling Pt:B.P. Text:2536F,1388C
Spec Gravity:2.13
Solubility in Water:APPRECIABLE
Appearance and Odor:WHITE SOLID FLAKES. ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG MINERAL ACIDS,AL,MG,ORGANIC MATLS,WATER,STRONG ORG AC
==================== Disposal Considerations ====================
Waste Disposal Methods:SMALL SPILL:DISSOLVE IN LARGE AMOUNT OF WATER &
NEUTRALIZE WITH 6M-HCL.FLUSH DOWN INTO AN APPROVED DISPOSAL AREA
WITH EXCESS WATER.LARGE SPILL:POUR INTO LARGE TANK OF WATER &
NEUTRALIZE.FLUSH TO AN AP PROVED DISPOSAL AREA W/LARGE EXCESS OF
WATER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:21570 BRAIN HEART INFUSION AGAR
CAGE:05545
CAGE:05545
CAGE:15481
============= Composition/Information on Ingredients =============
Ingred Name:PREPARED PLATED MEDIA CLASSIFIED AS GENERAL IN USE
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INDIVIDUALS W/KNOWN/SUSPECTED
ALLERGIES SHOULD ADVISE PHYSICIAN OF INCIDENT THAT MAY HAVE
RESULTED IN EXPOSURE TO ANTIBIOTIC TREATED MEDIA.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INDIVIDUALS W/KNOWN/SUSPECTED ALLERGIES SHOULD
ADVISE PHYSICIAN OF INCIDENT THAT MAY HAVE RESULTED IN EXPOSURE TO
ANTIBIOTIC TREATED MEDIA.
======================= First Aid Measures =======================
First Aid:OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATERSPRAY
Fire Fighting Procedures:IF PRODUCT BECOMES INVOLVED IN A FIRE,
EXTINGUISHING MEDIA FOR SURROUNDING MATERIAL SHOULD BE APPROPRIATE.
Unusual Fire/Explosion Hazard:PRODUCT WILL NOT BURN.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PAPER TOWELS TO PICK UP MATERIAL. WASH
AREA W/SOAP & WATER AFTER CLEANUP IS COMPLETE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER NORMAL PRODUCT USAGE.
Ventilation:NOT REQUIRED UNDER NORMAL PRODUCT USAGE.
Other Protective Equipment:NOT REQUIRED UNDER NORMAL PRODUCT USAGE.
Work Hygienic Practices:GOOD PERSONAL HYGIENE SHOULD BE PRACTICED.
Supplemental Safety and Health
WASTE CONT'D: CAREFULLY READ & FOLLOW DIRECTIONS. DISPOSE OF
IAW/FEDERAL, STATE & LOCAL REGULATIONS.
================== Physical/Chemical Properties ==================
Appearance and Odor:GELLED MEDIA OF VARYING COLORS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:OBSERVE ASEPTIC TECHNIQUES & ESTABLISHED
PRECAUTIONS AGAINST MICROBIOLOGICAL HAZARDS THROUGHOUT ALL
PROCEDURES. AFTER, USE PREPARED PLATES, SPECIMEN CONTAINERS & OTHER
CONTAMINATED MATERIALS, MUST BE STERILIZED BY AUTOCLAVING. (SEE
SUPP)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CEE BEE A-458
CAGE:8U841
CAGE:8U841
============= Composition/Information on Ingredients =============
Ingred Name:METHYLENE CHLORIDE (SARA 313) (CERCLA)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 70-90%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL ALCOHOL (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 10-15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1900 CU/METER
ACGIH TLV:1880 CU/METER
Ingred Name:TRIETHYL PHOSPHITE
CAS:122-52-1
RTECS #:TH1130000
Fraction by Wt: 2-5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Effects of Overexposure:EYE: IRRITATION, PAIN. SKIN: PROLONGED CONTACT
COULD CAUSE IRRIT, INFLAMMATION, BURNS. INHAL: DIZZINESS,
DRUNKENNESS, FATIGUE, HEADACHE. INGEST: NAUSEA, VOMIT.
Medical Cond Aggravated by Exposure:DERMATITIS, LIVER, KIDNEY DISEASES.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/WATER AT LEAST 15 MINUTES, GET MED AID. SKIN:
WASH IN FLOWING WATER W/SOAP AND WATER. INHAL: REMOVE TO FRESH AIR,
CALL DR. INGEST: DRINK LARGE QUANTITY OF WATER, DONT INDUCE VOMIT,
GET ME D AID OR TRANSPORT TO EMERGENCY MEDICALFACILITY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:WATER FOG
Fire Fighting Procedures:FULL PROTECTIVE GEAR, POSITIVE PRESSURE SCBA.
Unusual Fire/Explosion Hazard:FLAMMABLE VAPOR/AIR MIXTURES POSSIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:MOP, WIPE OR SOAK UP IMMED W/ABSORBENT. WEAR
PROPER PROTECTIVE EQUIPMENT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY WELL VENTILATED
AREA AT 32-90F.
Other Precautions:OPEN CONTAINER SLOWLY IN ORDER TO VENT IN CASE OF
PRESSURE BUILDUP.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TWA EXCEEDED, USE NIOSH/MSHA APPROVED
RESPIRATOR.
Ventilation:SUFFICIENT TO KEEP BELOW TWA LIMITS.
Other Protective Equipment:SUFFICIENT TO PREVENT SKIN CONTACT.
Work Hygienic Practices:EYEWASH STATION, SAFETY SHOWER.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:110F,43C
Melt/Freeze Pt:M.P/F.P Text:NA
Decomp Temp:Decomp Text:NA
Vapor Density:2.9 AIR=1
Spec Gravity:1.2
VOC Pounds/Gallon:454
pH:NA
Evaporation Rate & Reference:BUAC
Solubility in Water:SLIGHT
Appearance and Odor:HAZY, LIGHT COLORED LIQUID, SOLVENT ODOR.
Percent Volatiles by Volume:>90.0
Corrosion Rate:NA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:NA
Hazardous Decomposition Products:CHLORINE AND HYDROGEN CHLORIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE W/FEDERAL, STATE AND LOCAL
REGULATIONS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BUFFER, PH 7.00, YELLOW, 34170-157
CAGE:38445
CAGE:38445
============= Composition/Information on Ingredients =============
Ingred Name:2-BIPHENYLOL, SODIUM SALT; (DOWICIDE A) LD50(ORAL,RAT):565
MG/KG
CAS:132-27-4
RTECS #:DV7700000
Fraction by Wt: 0.05%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POTASSIUM PHOSPHATE, MONOBASIC; (POTASSIUM DIHYDROGEN
PHOSPHATE)
CAS:7778-77-0
Fraction by Wt: 0.35%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM MONOHYDROGEN PHOSPHATE; (DI-SODIUM HYDROGEN
PHOSPHATE) (CERCLA)
CAS:7558-79-4
RTECS #:WC4500000
Fraction by Wt: 0.58%
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PYRAZOLE-3-CARBOXYLIC ACID, 5-HYDROXY-1-(P-
SULFOPHENYL)-4-(P-SULFOPHENYL)AZO-, TRISODIUM SALT; (TARTRAZINE)
CAS:1934-21-0
RTECS #:UQ6400000
Fraction by Wt: 0.0006%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:NO INFORMATION AVAILABLE.
CHRONIC:DOWICIDE A IS LISTED AS A POSSIBLE CARCINOGEN BY IARC.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE IDENTIFIED.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES WHILE
HOLDING EYELIDS OPEN. HAVE EYES EXAMINED BY MEDICAL PERSONNEL.
SKIN:WASH WITH SOAP AND WATER. GET MEDICAL ATTENTION IF IRRITATION
DEVELOPS OR PERSISTS. INGESTION:DO NOT INDUCE VOMITING. GIVE GLASS
OF WATER OR MILK. CALL PHYSICIAN IMMEDIATELY. NEVER GIVE ANYTHING
BY MOUTH TO AN UNCONSCIOUS PERSON. INHALATION:REMOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE ANY SUITABLE FOR ADJACENT MATERIAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE IDENTIFIED. HAZARDOUS COMBUSTION
PRODUCTS:CO*X.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA OF ALL UNNEC PERS. WEAR SUITABLE
PROT EQUIP LISTED IN CTL MEASURES. CNTN RELS & ELIM IT'S SOURCE, IF
THIS CAN BE DONE W/OUT RISK. TAKE UP & CNTNRIZE FOR PROPER DISP AS
DESCRIBED UNDER WA STE DISP METH. COMPLY W/FED, STATE & LOC (SUP
DAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY AREA.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NONE SPECIFIED.
Ventilation:NONE SPECIFIED.
Other Protective Equipment:NONE SPECIFIED.
Work Hygienic Practices:HANDLE IN ACCORDANCE WITH GOOD
LABORATORY/INDUSTRIAL HYGIENE AND SAFETY PRACTICES.
Supplemental Safety and Health
SPILL PROC:REGULATIONS ON REPORTING RELEASES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Spec Gravity:1
pH:7.00
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR, YELLOW LIQUID, ODORLESS.
Percent Volatiles by Volume:99
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS.
Stability Condition to Avoid:HEAT.
Hazardous Decomposition Products:NONE. HAZARDOUS COMBUSTION
PRODUCTS:CO*X.
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS MATERIAL DOES NOT HAVE AN EPA WASTE NUMBER.
ALWAYS CONTACT A PERMITTED WASTE DISPOSER (TSD) TO ASSURE
COMPLIANCE WITH ALL CURRENT LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CLASSIC SUPER HEAVY DUTY BATTERY
CAGE:83740
CAGE:83740
============= Composition/Information on Ingredients =============
Ingred Name:MERCURY (SARA III)
CAS:7439-97-6
RTECS #:OV4550000
Fraction by Wt: 0-0.03%
Other REC Limits:NONE SPECIFIED
OSHA PEL:S, C, 0.1 MG/M3
ACGIH TLV:S, 0.05 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:MANGANESE DIOXIDE
CAS:1313-13-9
RTECS #:OP0350000
Fraction by Wt: 15-31%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG MN/M3 CEILING
ACGIH TLV:5 MG MN/M3
Ingred Name:ZINC (SARA III)
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: 7-42%
Other REC Limits:NONE SPECIFIED
OSHA PEL:10 MG ZNO/M3
ACGIH TLV:10 MG ZNO/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ZINC CHLORIDE (SARA III)
CAS:7646-85-7
RTECS #:ZH1400000
Fraction by Wt: 2-7%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 MG/M3/2 STEL
ACGIH TLV:1 MG/M3/2STEL FUME93
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: CAN CAUSE BURNS AND
PERMANENT INJURY DUE TO CAUSTIC POTASSIUM HYDROXIDE(KOH). MERCURY
AND OTHER METALS IN THIS BATTERY AND THEIR COMPOUNDS CAN CAUSE
CHRONIC HEALTH PROBLEMS SUCH AS SKIN IRR ITATION, CANCER, RENAL
FAILURE AND RESPIRATORY PROBLEMS. CHRONIC: NOT LIKELY UNDER PROPER
USE.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS BATTERY
ARE KNOWN OR SUSPECT CARCINOGENS.
Effects of Overexposure:EYE AND SKIN BURNS FROM POTASSIUM HYDROXIDE.
CENTRAL NERVOUS SYSTEM DISORDERS AND CANCERS FROM LONG TERM EFFECTS
OF HEAVY METAL POISONING.
Medical Cond Aggravated by Exposure:PERSONS WITH SKIN AND RESPIRATORY
DISORDERS MAY BE AT INCRESED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:FLUSH WITH WATER. FOR EYE OR SKIN CONTACT, FLUSH WITH LARGE
AMOUNTS OF WATER FOR 15 MINUTES AND CONTACT A PHYSICIAN
IMMEDIATELY. IF INHALATION EXPOSURE, REMOVE TO FRESH AIR AND
CONSULT A PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE DRY CHEMICAL AS APPROPRIATE FOR SURROUNDINGS.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY. CONTAIN RUNOFF.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID EYE AND SKIN CONTACT WHEN DISCARDING
USED BATTERIES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE IN A DRY
PLACE.
Other Precautions:AIR BREATHER UNITS ARE NEEDED IF MATERIALS ARE
INCINERATED. INCINERATION IS NOT RECOMMENDED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE 3M MASK 9908 FOR PROTECTION AGAINST MERCURY
VAPOR
Ventilation:GENERAL (MECHANICAL)
Other Protective Equipment:NONE REPORTED BY MANUFACTURER
Work Hygienic Practices:AVOID EYE/SKIN/RESPIRATORY CONTACT WITH LEAKING
BATTERIES.
Supplemental Safety and Health
THE MANUFACTURER CONSIDERS THIS BATTERY AS AN ARTICLE AS DEFINED IN
29CFR 1910.1200. UNDER NORMAL USE, IT DOES NOT RELEASE OR OTHERWISE
RESULT IN EXPOSURE TO A HAZARDOUS CHEMICAL.
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:NO APPRECIABLE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BATTERY CELLS CAN SHORT CIRCUIT IN WATER
Stability Condition to Avoid:HIGH HEAT >160F, OPEN FLAMES AND OTHER
SOURCES OF IGNITION, CHARGING, WATER
Hazardous Decomposition Products:BATTERY MAY EMIT HAZARDOUS VAPORS OF
POTASSIUM HYDROXIDE AND MANGANESE, MERCURY AND ZINC OXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE. BROKEN BATTERIES OR WITH
LEAKING ELECTROLYTE MAY CONSTITUTE HAZARDOUS WASTE. CONSULT WASTE
DISPOSAL OFFICIALS FOR ADVICE.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:FORMULA 797
CAGE:53798
CAGE:53798
============= Composition/Information on Ingredients =============
Ingred Name:PYRETHRINS
CAS:8003-34-7
RTECS #:UR4200000
Fraction by Wt: 1%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:PIPERONYL BUTOXIDE
CAS:51-03-6
RTECS #:XS8050000
Fraction by Wt: 10%
Ingred Name:SYNTHETIC CRYSTALLINE-FREE SILICA GEL *93-4*
CAS:112926-00-8
Fraction by Wt: 40%
ACGIH TLV:10 MG/CUM
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; PETROLEUM DISTILLATE,
HYDROTREATED ,(MINERAL SPIRITS)
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 49%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): >5 G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DIRECT CONTACT W/EYES MAY RESULT IN
IRRITATION. PROLONGED CONTACT W/THE SKIN MAY ALSO RESULT IN
IRRITATION. HARMFUL IF SWALLOWED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:INGESTION: DON'T INDUCE VOMITING. ASPIRATION HAZARD. EYES:
FLUSH W/PLENTY OF COOL WATER FOR 15 MINS. SKIN: WASH W/PLENTY OF
SOAP & WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:192F
Extinguishing Media:WATERFOG, FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:USE SCBA IN ENCLOSED AREAS. KEEP CONTAINERS
COOL.
Unusual Fire/Explosion Hazard:THE POWDER CAN BE IGNITED W/A MATCH &
WILL BURN MODERATELY.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP & DISPOSE OF W/CHEMICAL WASTE. DON'T
CONTAMINATE FOOD, FEED/WATER BY STORAGE/DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE UPRIGHT & AT ROOM TEMPERATURE
AWAY FROM MOISTURE. TOXIC TO FISH. DON'T APPLY DIRECTLY TO
WATERWAYS.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. NOT FOR HOUSEHOULD
USE/RESALE. DON'T APPLY WHEN WEATHER CONDITIONS FAVOR DRIFT FROM
AREAS TREATED. DON'T APPLY WHERE RUNOFF IS LIKELY TO OCCUR.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DUST MASK IF DUSTING OCCURS
Ventilation:LOCAL EXHAUST: ADEQUATE
Work Hygienic Practices:DON'T WEAR CONTACT LENSES WHILE USING THIS
PRODUCT.
Supplemental Safety and Health
KEEP OUT OF REACH OF CHILDREN. DON'T CONTAMINATE WATER BY CLEANING
EQUIPMENT/DISPOSAL OF WASTES.
================== Physical/Chemical Properties ==================
Solubility in Water:SLIGHT
Appearance and Odor:FLUFFY WHITE TO OFF WHITE POWDER W/SLIGHT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STONG OXIDIZERS. DON'T MIX W/OTHER PRODUCTS.
Stability Condition to Avoid:OPEN FLAMES, MOISTURE
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T REUSE EMPTY CONTAINERS FOR ANY PURPOSE.
FOR PAILS & DRUMS, EMPTY RESIDUE FROM LINER, RINSE PAIL THOROUGHLY
W/WATER, THEN DISCARD. FOR CONTAINERS <1LB: WRAP IN PAPER & DISCARD
IN TRASH. DISPOSE I AW/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:INTEX 8790
CAGE:HO425
CAGE:78304
CAGE:HO425
============= Composition/Information on Ingredients =============
Ingred Name:CRESOL, ALL ISOMERS (CRESYLIC ACID) (SARA III)
CAS:1319-77-3
RTECS #:GO5950000
OSHA PEL:S, 5 PPM
ACGIH TLV:S, 5 PPM; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:CHROMIUM ION (CR 6+)
CAS:18540-29-9
RTECS #:GB6262000
Fraction by Wt: <0.2%
OSHA PEL:C, 0.1 MG/M3 (CRO3)
ACGIH TLV:0.05 MG/M3 (CR);8990
Ingred Name:METHYLENE CHLORIDE(SARA III)
CAS:75-09-2
RTECS #:PA8050000
OSHA PEL:500 PPM/C,1000; Z2
ACGIH TLV:50 PPM, A2; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:SKIN: DRYING.EYE: IRRIT. INHAL: EYE &
RESPIRATORY IRRIT,DIZZ,NAUS,POSSIBLE UNCONSCIOUSNESS
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR,APPLY ARTIF RESP IF NEC,GET
MEDICAL AID. EYE/SKIN: FLUSH W/WATER FOR 15 MINUTES GET MEDICAL
AID.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:CO*2,FOAM
Fire Fighting Procedures:WEAR SELF CONT BRTH APPAR
Unusual Fire/Explosion Hazard:SHOULD NOT BE STORED AT TEMP ABOVE 105F.
NO EXPLOSIVE CHARACTERISTICS.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH W/ DETERGENT & WATER & MOP DRY.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE IN AREAS ABOVE 105F. USE
SAFETY PRECAUTIONS FOR HANDLING ALKALINE SOLVENT PRODUCTS.
Other Precautions:NO SMOKING,FLAME CUTTING,ARC WELDING,OPEN FLAME OR
HOT SURFACES IN AREA OF USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD SCBA OR INDUSTRIAL
CANISTER-TYPE MASK (MFR)
Ventilation:LOCAL-TO KEEP CONC BELOW TLV
Other Protective Equipment:RUBBER BOOTS & APRON
Supplemental Safety and Health
SPEC: TYPE II(DIPHASE). SPECIFIC GRAVITY: 1.14-1.18. CONTAINER: 5
GALLON CAN
================== Physical/Chemical Properties ==================
HCC:T4
Boiling Pt:B.P. Text:105F;41C
Vapor Density:>1
Evaporation Rate & Reference:>1 (NBUAC=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:REDDISH TO RUST COLOR W/CRESYLIC ACID ODOR
Percent Volatiles by Volume:90
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:DO NOT LOSE WATER SEAL
Hazardous Decomposition Products:THERMAL DECOMP: CO,OXIDES OF
NITROGEN,SULFUR & PHOSGENE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IAW FED, STATE & LOCAL CODES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:8403888, 84-3890, AMMONIUM DICHROMATE
CAGE:59896
Contract Num:MDA414-98-A-0118-0106
CAGE:59896
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIUM DICHROMATE
CAS:7789-09-5
RTECS #:HX7650000
= Wt:100.
OSHA PEL:SEE TABLE Z-2
ACGIH TLV:0.05 MG/M3
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 67.5 MG/KG
Reports of Carcinogenicity:NTP:YES IARC:YES
Health Hazards Acute and Chronic:TARGET ORGANS: SKIN AND RESPIRATORY
TRACT.PRIMARY ROUTE (S) OF ENTRY: LUNGS AND KIDNEYS. POTENTIAL
HEALTH EFFECTS: EYES-MAY CAUSE IRRITATION. SKIN-MAY CAUSE
IRRITATION. INGESTION-MAY CAUSE GASTROIN TESTINAL DISCOMFORT.
INHALATION- MAY CAUSE IRRITATION TO RESPIRATORY TRACT.
Explanation of Carcinogenicity:LISTED AS CAUSING CANCER BY NTP AND
IARC.
Medical Cond Aggravated by Exposure:SKIN AND RESPIRATORY.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH WATER FOR 15 MINS, RAISING & LOWERING EYELIDS
OCCASIONALLY. GET MEDICAL ATTENTION IF IRRITATION PERSISTS.
SKIN:THOROUGHLY WASH EXPOSED AREA FOR 15 MINS. REMOVE CONTAMINATED
CLOTHING. G ET MEDICAL ATTENTION IF IRRITATION PERSISTS. INGESTION:
IF SWALLOWED, IF CONSCIOUS, GIVE PLENTY OF WATER & INDUCE VOMITING
IMMEDIATELY AS DIRECTED BY MEDICAL PERSONNEL. IMMEDIATELY CALL
PHYSICIAN/POIS ON CONTROL. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCINSCIOUS PERSON. INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN IF
BREATHING IS DIFFICULT; GIVE ARTIFICIAL RESPIRATION IF STOPPED.
KEEP PERSON WARM, Q UIET, & GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE DRY CHEMICAL, CO2 OR APPROPRIATE FOAM.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR FULL PROTECTIVE
EQUIPMENT AND NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CONTACT WITH OTHER MATERIAL MAY CAUSE
FIRE. MAY EMIT FUMES AND CONTAINER MAY EXPLODE UNDER FIRE
CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA OF SPILL. CLEAN-UP PERSONNEL
SHOULD WEAR PROPER PROTECTIVE EQUIPMENT. AVOID CREATING DUST. SWEEP
OR SCOOP UP AND CONTAINERIZE FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTAINER MAY EXPLODE AND EMIT TOXIC
FUMES UNDER FIRE CONDITIONS.
Other Precautions:KEEP OUT OF CONTACT WITH OTHER MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NEEDED UNDER NORMAL CONDITIONS OF USE WITH
ADEQUATE VENTILATION. NIOSH APPROVED EQUIPMENT SHOULD BE WORN IF
PELS ARE EXCEEDED.
Ventilation:LOCAL:PREFERRED. MECHANICAL:ACCEPTED
ALL TIMES.
Other Protective Equipment:LAB COAT, EYE WASH, AND SAFETY SHOWER.
Work Hygienic Practices:LAUNDER CONTAMINATED CLOTHING BEFORE RESUE.
Supplemental Safety and Health
84-3888.
================== Physical/Chemical Properties ==================
HCC:D1
Melt/Freeze Pt:M.P/F.P Text:DECOMPOSED @180C
Decomp Temp:=180.C, 356.F
Spec Gravity:2.15
Solubility in Water:36.4G/100G H2O@20C
Appearance and Odor:BRIGHT, ORANGE-RED CRYSTALS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:NO DATA AVAILABLE.
=================== Toxicological Information===================
Toxicological Information:ACGIH-TLV 0.5MG(CR)/M3. OSHA-PEL 0.05
MG(CR)/M3.
===================== Ecological Information =====================
Ecological:EPA WASTE NUMBERS: NO DATA AVAILABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL REGULATIONS. ALWAYS CONTACT A PERMITTED
WASTE DISPOSER (TSD) TO ASSURE COMPLIANCE.
=================== MSDS Transport Information ===================
Transport Information:DESCRIPTION: AMMONIUM DICHROMATE, 5.1, UN 1439,
II.
===================== Regulatory Information =====================
SARA Title III Information:HAZARD CATEGORY FOR SARA SECTION 311/312
REPORTING: ACUTE, CHRONIC.
Federal Regulatory Information:EPA TSCA STATUS: ON TSCA INVENTORY.
CERCLA SEC. 103 RQ LBS: AMMONIUM DICHROMATE: 1000 LBS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DX77 FISH EYE PREVENTER
CAGE:EO471
CAGE:EO471
============= Composition/Information on Ingredients =============
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 95-100%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:FILM FORMERS, RESINS, & ADDITIVES
Fraction by Wt: 1-2%
Ingred Name:WEIGHT PER GALLON IN POUNDS: 7.22
RTECS #:9999999WG
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: HARMFUL OR FATAL.
EYES/SKIN: IRRITATION. INHALATION: HARMFUL, NOSE/THROAT/RESPIRATORY
SYSTEM IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INGESTION: HARMFUL OR FATAL. EYES: REDNESS,
ITCHING, BURNING SENSATION & VISUAL DISTURBANCES. SKIN: DRYNESS,
ITCHING, CRACKING, BURNING, REDNESS & SWELLING. INHALATION: EYE
WATERING, HEADACHES, NAUSEA , DIZZINESS, LOSS OF COORDINATION,
PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
======================= First Aid Measures =======================
First Aid:INGESTION: GIVE 1 OR 2 GLASSES OF WATER. DON'T INDUCE
VOMITING. EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 30 MINS. SKIN:
FLUSH W/PLENTY OF WATER, THEN BY WATERLESS HAND CLEANER & SOAP &
WATER. INHALA TION: REMOVE TO FRESH AIR. APPLY ARTIFICIAL
RESPIRATION & OTHER SUPPORTIVE MEASURES. OBTAIN MEDICAL ATTENTION
IN ALL CASES. HAVE MATERIAL SAFETY DATA SHEET INFORMATION
AVAILABLE.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:80F
Lower Limits:1.1%
Extinguishing Media:CO2, DRY CHEMICAL, OR UNIVERSAL AQUEOUS FILM
FORMING FOAM.
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. USE WATER
SPRAY TO COOL CLOSED CONTAINERS. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE. USE SCBA.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY BUILD UP PRESSURE,
AUTOIGNITE OR EXPLODE WHEN EXPOSED TO EXTREME HEAT. DON'T APPLY TO
HOT SURFACES. ISOLATE FROM IGNITION SOURCES.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. ONLY PERSONNEL EQUIPPED
W/PROTECTIVE EQUPMENT SHOULD BE PERMITTED IN AREA. TAKE UP SPILL
MATERIAL W/SAWDUST, VERMICULITE OR OTHER ABSORBENT MATERIAL & PLACE
INTO CONTAINERS FOR DISPOSA L. REMOVE IGNITION SOURCES.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE >120F. STORE LARGE
QUANTITIES IN BLDGS DESIGNED & PROTECTED FOR STORAGE OF NFPA CLASS
1B FLAMMABLE LIQUIDS. KEEP CONTAINERS TIGHTLY CLOSED
Other Precautions:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING &
INHALING CONTENTS CAN BE HARMFUL OR FATAL. GROUND CONTAINERS WHEN
POURING. AVOID FREE FALL OF LIQUIDS IN EXCESS OF A FEW INCHES.
DON'T APPLY TO HOT S URFACES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH/MSHA APPROVED (TC-23C) AIR PURIFYING
OR AIR SUPPLIED (TC-19C) RESPIRATOR.
Ventilation:GENERAL DILUTION OR LOCAL EXHAUST IN VOLUME & PATTERN TO
KEEP BELOW TLV & REMOVE DECOMPOSITION PRODUCTS.
Other Protective Equipment:IMPERMEABLE APRON
Work Hygienic Practices:CLEAN OR DISCARD CONTAMINATED CLOTHING & SHOES.
Supplemental Safety and Health
PERCENT SOLID BY WEIGHT: 1.01
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:138-145C
Vapor Pres:4.9
Vapor Density:>1
Spec Gravity:0.87
Evaporation Rate & Reference:(BU AC = 100): 63
Solubility in Water:INSOLUBLE
Appearance and Odor:VISCOUS LIQUID W/AN ODOR CHARACTERISTIC OF SOLVENTS
Percent Volatiles by Volume:99.10%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, STRONG MINERAL ACIDS, OR STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, HOT SURFACES, OR
OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. RECYCLE OR DISPOSE EMPTY CONTAINERS AT AN
APPROVED WASTE MANAGEMENT FACILITY.
| 1 | gloves_mandatory |
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.