text
stringlengths 542
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:7133 MOJUD PINK, 8049578
CAGE:DO804
CAGE:DO804
CAGE:38360
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2-(2-BUTOXYETHOXY)-, ACETATE; (DIETHYLENE GLYCOL
MONOBUTYL ETHER ACETATE)
CAS:124-17-4
RTECS #:KJ9275000
Fraction by Wt: 10-25%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MODERATE IRRITATION, REDNESS,
TEARING. SKIN: SLIGHT IRRITATION. INHAL: NASAL & RESP IRRITATION,
CENTRAL NERVOUS SYSTEM EFFECTS INCLUDING DIZZINESS, WEAKNESS,
FATIGUE, NAUSEA, HEADACHE AND POSSIB LE UNCONSCIOUSNESS & EVEN
DEATH. INGEST: GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING &
DIARRHEA.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:NOTES TO PHYSICIAN: CHRONIC OVEREXPOSURE TO
DIETHYLENE GLYCOL MONOBUTYL ETHER ACETATE IN ANIMALS HAS BEEN
REPORTED TO CAUSE KIDNEY DAMAGE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MINUTES. CALL MD IMMED.
SKIN: WASH W/SOAP & WATER FOR AT LEAST 15 MINUTES. GET MED ATTN.
INHAL: REMOVE TO FRESH AIR. ADMIN OXYGEN IF BREATHING IS DIFFICULT.
BEGIN R ESUSCITATION IF BREATHING HAS STOPPED. KEEP PERSON WARM &
QUIET. GET MED ATTN IMMED. INGEST: IF CONSCIOUS, GIVE TWO GLASSES
OF WATER & INDUCE VOMITING. GET MED ATTN IMMED.
===================== Fire Fighting Measures =====================
Flash Point:237F,114C
Extinguishing Media:DRY CHEMICAL, CO*2, ALCOHOL FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR & MAY TRAVEL
ALONG THE GROUND & MAY BE IGNITED AT DISTANT LOCATIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIM ALL SOURCES OF IGNIT. ABSORB SPILLED MATL
W/VERMICULITE OR FLOOR ABSORB. DISP OF CONTAMD MATLS PROPERLY. USE
TO OSHA STD: 29CFRPT 1910.120 HAZ WASTE OPS AND EMER RESPONSE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:FOR FLAMMABLE/COMBUSTIBLE PRODUCTS
FOLLOW STORAGE & HANDLING GUIDELINES PRESENTED IN NFPA 30 FLAMMABLE
& COMBUSTIBLE LIQUIDS CODE.
Other Precautions:CNTNRS OF THESE MATLS MAY BE HAZ WHEN EMPTIED, SINCE
EMPTIED CNTNRS RETAIN PROD RESIDUES WHICH CAN GENERATE VAPS W/IN
FLAMMABLE LIMITS. THE USE OF HAZ CHEM MAY REQ SUPPLEMENTAL VENT FOR
PROT OF PERS & FOR CONTROLLING FIRE/EXPLO (SUPP DATA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD RESP APPROP FOR EXPOS OF
CONCERN. SUFFICIENT TO MNTN OPERATOR EXPOS BELOW APPLIC OCCUP EXPOS
STDS. ENGINEERING/ADMIN CONTROLS OF NIOSH/MSHA RESPS CAN BE USED TO
REDUCE EXPOS. E NGINNERING CONTROLS ARE PREF BY OSHA.
Ventilation:SUFFICIENT TO MAINTAIN OPERATOR EXPOSURE BELOW APPLICABLE
OCCUPATIONAL EXPOSURE STANDARDS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:LAUNDER CONTAMINATED CLOTHING BEFORE REUSE. GET
MEDICAL ATTENTION.
Supplemental Safety and Health
WASTE DISP METH: MATL HAZARDOUS. CONTACT FED, STATE & LOC AUTHORITIES
FOR DISP INFO. CONSULT 40CFR PART 261 IDENTIFICATION & LISTING OF
HAZARDOUS WASTE. OTHER PRECS: HAZARD. A QUALIFIED INDEPENDENT TE
STING COMPANY CAN DETERMINE IF THE EXISTING CONC ARE WITHIN THE
ESTABLISHED RECOMMENDED/PERMISSIBLE EXPOSURE LEVELS.
================== Physical/Chemical Properties ==================
Vapor Pres:VERY LOW
Evaporation Rate & Reference:VERY SLOW
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIQUID OR SEMI-SOLID INK AS COLOR ABOVE.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, STRONG MINERAL ACIDS.
Stability Condition to Avoid:HEAT & FLAME.
Hazardous Decomposition Products:CO, CO*2.
==================== Disposal Considerations ====================
Waste Disposal Methods:UNDER RESOURCE CONSERVATION & RECOVERY
ACT(RCRA), IT IS RESPONSIBLITY OF GENERATOR OF WASTE TO DETERMINE
WHETHER WASTE GENERATED MEETS FED, STATE, LOC HAZ WASTE CRITERIA.
USES, TRANSFORMATIONS, MIXTUR ES, PROCESSES,ETC., MAY RENDER RSLTG
(SUPP DATA)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BOSTIK ADH 1008B
Kit Part:Y
Preparer's Name:D. C. MOLBERG
CAGE:60775
CAGE:60775
CAGE:60777
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ACETATE (ETHYL ETHANOATE)
CAS:141-78-6
RTECS #:AH5425000
Fraction by Wt: 28.1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 27.2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ZINC OXIDE
CAS:1314-13-2
Fraction by Wt: 17.0%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15MG/M3 TDUST/5 FUME
ACGIH TLV:10MG/M3 TDUST; 9293
Ingred Name:TLV FOR VAPORS IS 165 PPM
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50(ORAL)50-500 MG/KG. LC50 200-2000PPM
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:LONG TERM OVEREXPOSURE TO TOLUENE HAS
BEEN ASSOCIATED WITH KIDNEY AND LIVER DAMAGE. INGESTION: HAZARDOUS
IF INGESTED. INHALATION: HAZARDOUS IF INHALED. EYE: IRRITATION.
Effects of Overexposure:IRRITATION, DIZZINESS, BREATHING DIFFICULTY,
WEAKNESS, NAUSEA, VOMITING, DIARRHEA, NARCOSIS.
======================= First Aid Measures =======================
First Aid:INGEST: IF SWALLOWED. DO NOT INDUCE VOMITING AS THIS MAY
CAUSE FURTHER COMPLICATIONS. CALL A PHYSICIAN. INHAL: REMOVE TO
FRESH AIR. IF NOT BREATHING-GIVE ARTIFICIAL RESPIRATION (PREFER
MOUTH- MOUTH) I F BREATHING DIFFICULT-GIVE OXYGEN. CALLA PHYSICIAN.
EYE: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:14F,-10C
Lower Limits:1.61%
Upper Limits:9.31%
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE, FLOOD WITH
WATER.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:USE SELF-CONTAINED BREATHING APPARATUS.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP LIQUID WITH AN ABSORBENT MATERIAL
(SAND/EARTH/SWEEPING COMPOUND/OTHER ABSORBENT MATERIAL). PACKAGE
ABSORBENT MATERIAL OR SOLID PRODUCT IN STEEL DRUMS WHICH ARE IN
GOOD CONDITION. THOROUGHLY CL EAN AREA WHERE SPILL OCCURRED.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL LOCATION (60-80F) AWAY
FROM SUNLIGHT & ANY SOURCE OF HEAT/SPARKS/FLAME. KEEP CONTAINER
TIGHTLY CLOSED WHEN NOT BEING USED.
Other Precautions:USE W/ADEQUATE VENT, AVOID PROLONG/REPEAT BREATHING
OF VAPORS. AVOID SKIN CONTACT. USE IN AN AREA FREE FROM
FLAME/SPARKS. ##CLASSIFIED AS A HAZARDOUS WASTE UNDER FEDERAL
REGULATIONS IN EFFECT AT THE T IME OF PRINTING OF THIS MSDS.
============= Exposure Controls/Personal Protection =============
Ventilation:LOCAL EXHAUST IS PREFERRED, MECHANICAL EXHAUST IS
ACCEPTABLE.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:133 TO 245F
Vapor Pres:64
Vapor Density:3.11
Spec Gravity:1.10
Evaporation Rate & Reference:3.1 (BUTYL ACETATE =1)
Solubility in Water:2.3%
Appearance and Odor:A TAN LIQUID WITH A SWEET ODOR.
Percent Volatiles by Volume:69.4
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, STRONG ACIDS OR ALKALIS.
Hazardous Decomposition Products:UNKNOWN DUE TO THE COMPLEX NATURE OF
THIS MATL. FUMES FROM COMPLETE/INCOMPLETE COMBUSTION OF THIS MATL
MAY INCLUDE:Hazardous Polymerization Indicator:NO
Conditions to Avoid Polymerization:CO/CO2/WATER VAPOR/OXIDES OF
NITROGEN/WIDE VARIETY OF INNOCUOUS OR TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORD W/FED, ST & LOCAL REG. BE
AWARE THAT ST & LOCAL REQ MAY DIFFER DEPENDING ON LOCATION & IN
MANY CASES BE DIFFERENT FROM FEDERAL RULES. WHEN INTENDING TO
DISPOSE OF THIS MATERIAL, T HE USER IS ADVISED THAT THIS PROD
WOULDBE##
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SYNTHETIC GRAPHITE
Preparer's Name:WILFRED M. KENAN
CAGE:84195
CAGE:84195
============= Composition/Information on Ingredients =============
Ingred Name:GRAPHITE, NATURAL
CAS:7782-42-5
RTECS #:MD9659600
Fraction by Wt: 100%
OSHA PEL:15 MPPCF RDUST
ACGIH TLV:2 MG/M3 RDUST; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: PULMONARY FIBROSIS,
EMPHYSEMA, CORPULMONALE. SKIN/EYES: MINOR IRRITATION, REDNESS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: PULMONARY FIBROSIS, EMPHYSEMA,
CORPULMONALE. EYE/SKIN: MINOR IRRITATION, REDNESS.
Medical Cond Aggravated by Exposure:EMPHYSEMA, ASTHMA.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM DUST AREA, TO FRESH CLEAN AIR.
INGESTION: DRINK WATER. EYE: WASH W/WATER. SKIN: WASH W/MILD SOAP &
WARM/COLD WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:CAN BE USED TO EXTINGUISH FIRE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM UP. NO SPECIAL TREATMENT REQUIRED.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE REQUIRED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN OVER 15 MPPCF USE OSHA APPROVED RESPIRATOR.
Ventilation:SUPPLY FRESH MOVING AIR.
Other Protective Equipment:NO SPECIAL CLOTHING REQUIRED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:2.26
Solubility in Water:INSOLUBLE
Appearance and Odor:DARK, GRAY, BLACK.
Percent Volatiles by Volume:.1%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN/SANITARY LANDFILL. NOT REGULATED BY RCRA.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DOLOMITIC HYDRATED LIME
CAGE:ODGV3
CAGE:ODGV3
============= Composition/Information on Ingredients =============
Ingred Name:CALCIUM HYDROXIDE
CAS:1305-62-0
RTECS #:EW2800000
Fraction by Wt: <50%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:5 MG/M3; 9293
Ingred Name:MAGNESIUM HYDROXIDE
CAS:1309-42-8
RTECS #:OM3570000
Fraction by Wt: >35%
Ingred Name:CALCIUM CARBONATE (MARBLE) (LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: <8%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9192
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <1%
Other REC Limits:0.05 MG/CUM NIOSH
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:ALPHA-ALUMINA (ALUMINUM OXIDE) (EPA LISTS ONLY FIBROUS
FORMS) (SARA III)
CAS:1344-28-1
RTECS #:BD1200000
Fraction by Wt: <1%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:IRON OXIDE
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: <1%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: CAUSE IRRITATION & POSSIBLE
SEVERE CORROSION DAMAGE. INHALATION: MAY CAUSE COUGHING, SNEEZING,
OR INFLAMMATION OF THE RESPIRATORY PASSAGES. PREVENTION OF CONTACT
& EXPOSURE UNDER GOOD WORKI NG CONDITIONS IS MUCH PREFERRED TO
FIRST AID AFTER INJURY.
Explanation of Carcinogenicity:IT CONTAINS DETECTABLE AMTS OF CHEMICALS
KNOWN TO CALIFORNIA TO CAUSE CANCER, BIRTH DEFECTS OR REPRODUCTIVE
HARM.
Effects of Overexposure:SKIN: WHILE SHORT TERM EXPOSURE & IRRITATION
ARE GENERALLY W/O PERMANENT EFFECTS, UNTREATED CONTACT & IRRITATION
CAN CAUSE DERMATITIS & CHEMICAL BURNS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE TO DUST & GET PROMPT MEDICAL
HELP. EYE: WASH W/RUNNING WATER FOR 15 MINUTES, INCLUDING UNDER
EYELIDS. GET PROMPT MEDICAL ATTENTION. SKIN: WASH AREA W/LARGE
AMOUNTS OFWATER. REMOVE & WASH CONTAMINATED CLOTHING. INGESTION:
DILUTE THE CHEMICAL BY DRINKING LARGE AMOUNTS OF WATER OR MILK.
THEN NEUTRALIZE BY DRINKING DILUTE VINEGAR OR FRUIT JUICE.
===================== Fire Fighting Measures =====================
Extinguishing Media:NOT FLAMMABLE
Fire Fighting Procedures:IF TEMPS >662F PREVAIL, WEAR SCBA. THE
PRESENCE OF TYPE S HYDRATED LIME IN A FIRE DOESN'T HINDER THE USE
OF ANY STANDARD EXTINGUISHING MEDIA.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:CAREFULLY PICK UP THE SOLID W/A MINIMUM OF
DUSTING/COLLECT IN METAL CONTAINERS W/COVERS FOR DISPOSAL. THE
SMALL AMTS OF RESIDUE AFTER SHOVELING & SWEEPING CAN BE FLUSHED TO
THE DRAIN, USING PLENTY OFWATER.
Neutralizing Agent:ACID OR WASTE ACID.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE MATERIALS IN SEALED CONTAINERS
IN A DRY PLACE. AVOID CONTACT W/ACIDS & OTHER INCOMPATIBLE
MATERIALS. PROTECT EYES FROM DUST.
Other Precautions:EXPOSURE TO AIR LOWERS THE AVAILABLE DOLOMITIC
HYDRATED LIME REACTIVITY OVER TIME. DRY AREA, OUT OF WEATHER/FLOOD
DANGER. AVOID DUSTING IN HANDLING. STANDARD EQUIPMENT FOR HYDRATED
LIME USE. MAKE ADEQ UATE PROVISION FOR DUST-FREE OPERATIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED DUST FILTER RESPIRATOR IN DUSTY
CONDITIONS. IN ABSENCE OF DUST, MECHANICAL EXHAUST IS ADEQUATE.
Ventilation:PROVIDE MECHANICAL & LOCAL EXHAUST VENTILATION TO KEEP
<TLV.
Other Protective Equipment:AN EYEWASH STATION. CLEAN, BODY-COVERING
PROTECTIVE CLOTHING, LONG-SLEEVE SHIRT W/BUTTONED COLLAR; LONG
PANTS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:5162F
Melt/Freeze Pt:M.P/F.P Text:350C
Solubility in Water:SLIGHT
Appearance and Odor:TYPE S HYDRATED LIME IS AVAILABLE IN BULK AS A FINE
POWDER, 95% PASSING 200 MES
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, AMMONIUM SALTS, PHOSPHORUS, & SOME ORGANIC COMPOUNDS. CONTACT
W/NITROPARAFFINS, MALEIC ANHYDRIDE.
Stability Condition to Avoid:EXPOSURE TO AIR. THIS FORMS LUMPS, REDUCES
THE CHEMICAL ACTIVITY & RESULTS IN A LIMITED SHELF LIFE.
Hazardous Decomposition Products:WHEN EXPOSED TO AIR FORMS CALCIUM
CARBONATE. CALCIUM & MAGNESIUM SALTS ARE NORMAL REACTION PRODUCTS.
Conditions to Avoid Polymerization:REACTS W/ACIDS, FORMING CALCIUM
SALTS WHICH MAY BE SOLUBLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:SPREAD IN A PROTECTED AREA TO PERMIT REACTION
WITH CARBON DIOXIDE IN AIR. USE AS A SOIL AMENDMENT. USE TO
STABILIZE CLAY SOILS. FOLLOW FEDERAL, STATE, & LOCAL REGULATIONS.
NEUTRALIZE W/ACID OR WASTE A CID.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:23F1209
CAGE:01002
CAGE:01002
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMED.SKIN WASH W/WATER IMMED.INHAL:REMOVE
TO FRESH AIR.GIVE ART.RESPIR. AS NEEDED.INGEST:GET MEDICAL
ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE VOMITING,BUT DO NOT MAKE
UNCONSCIOUS P ERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT.
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS.CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:V1
Appearance and Odor:LIGHT STRAW COLORED LIQUID,AROMATIC ODOR.
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:16-692 RESIN-HYDROCARBON
CAGE:59581
CAGE:59581
============= Composition/Information on Ingredients =============
Ingred Name:METHANOL (METHYL ALCOHOL), COLUMBIAN SPIRITS
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 6-7%
Other REC Limits:200 PPM
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TITANIUM DIOXIDE, TIO2
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 7-10%
Other REC Limits:375 MG/CUM
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:V M & P NAPHTHA, LIGROINE, MINERAL SPIRITS
CAS:8032-32-4
RTECS #:OI6180000
Other REC Limits:STEL 400 PPM
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 1-4%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
CAS:75-28-5
RTECS #:TZ4300000
Other REC Limits:1000 PPM
OSHA PEL:1800 MG/CUM
ACGIH TLV:1000 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY SYSTEM
IRRITATION. EYES: IRRITATION. INGESTION: ACCIDENTAL INGESTION IS
UNLIKELY FROM AN AEROSOL CAN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION:
IRRITATION/HEADACHE/DIZZINESS/NAUSEA/UNCONSCIOUS/ASPHYXIA. SKIN:
DEFATTING LEADING TO IRRITATION/DERMATITIS. METHYL ALCOHOL: CNS
(OPTIC NERVE) EFFECTS/FATAL/BLINDNESS/POISONOUS ABSORPTION/ LIVER
DAMAGE/DEATH. VM&P: SKIN IRRITATION/CNS DEPRESSION. TOLUENE:
CARDIAC EFFECTS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING STOPS, BEGIN
ARTIFICIAL RESPIRATION. EYES: IMMEDIATELY FLUSH W/PLENTY OF WATER
FOR AT LEAST 15 MINS. SKIN: WASH W/SOAP & WATER. INGESTION: OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:-10F
Lower Limits:0.7%
Upper Limits:9.5%
Extinguishing Media:CO2, DRY CHEMICAL, OR FOAM
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. WATER MAY BE
USED TO COOL CONTAINERS TO PREVENT BURSTING. IF WATER IS USED, FOG
Unusual Fire/Explosion Hazard:EXPOSURE TO HEAT OR PROLONG EXPOSURE TO
SUN MAY CAUSE BURSTING.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
BREATHING VAPORS. VENTILATE AREA. WIPE UP W/INERT MATERIALS & PLACE
IN APPROPRIATE CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE >120F. USE ONLY AS
DIRECTED. AVOID CONTINUOUS BREATHING OF VAPORS & SPRAY MIST.
Other Precautions:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING
VAPORS & INHALING CONTENTS CAN BE HARMFUL OR FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR SELF-CONTAINED BREATHING APPARATUS FOR
CONCENTRATIONS ABOVE TLV LIMITS.
Ventilation:USE W/ADEQUATE VENTILATION, SUFFICIENT TO PREVENT
INHALATION OF SOLVENT VAPORS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Pres:40 PSIA
Vapor Density:>1
Evaporation Rate & Reference:FASTER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:PAINT SOLVENT ODOR.
Percent Volatiles by Volume: 85%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:TEMPS >120F, SPARKS, PILOT LIGHT, OPEN
FLAME, SUN, OR OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:HAZARDOUS FUMES SUCH AS CO, CO2,
PHOSGENE, HYDROGEN CHLORIDE, & CHLORINATED ACIDS, ALDEHYDES, &
KETONES
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T INCINERATE AEROSOL, DISPOSE OF IN
ACCORDANCE W/LOCAL, STATE, & FEDERAL REGULATIONS. DON'T PLACE
AEROSOL CANS IN HOME COMPACTOR. DON'T PUNCTURE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PASA-VEL 107M(LIQUID NORM. SOLN)
CAGE:0AEP5
CAGE:0AEP5
============= Composition/Information on Ingredients =============
Ingred Name:CHROMIC ACID (SARA III)
CAS:7738-94-5
RTECS #:GB2450000
Fraction by Wt: 2.0%
OSHA PEL:0.1 MG CRO3/M3;CEILG
ACGIH TLV:0.05 MG/M3
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:NITRIC ACID (SARA III)
CAS:7697-37-2
RTECS #:QU5775000
Fraction by Wt: 17.0%
OSHA PEL:2 PPM/4 STEL
ACGIH TLV:2 PPM/4 STEL; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:EYES,SKIN:BURNS;INHALE,INGEST:HARMFUL TO MUCOUS
MEMBRANES;ULCERATION FROM PROLONGED CONTACT.
======================= First Aid Measures =======================
First Aid:INHALE:REMOVE TO FRESH AIR;EYES:FLUSH W LG AMTS
H*2O;SKIN:FLUSH W LG AMTS SOAP,H*2O;INGEST:GIVE MILK OF
MAGNESIA,MILK, OR EGG WHITE BEATEN W H*2O(AVOID
CARBONATES);IMMEDIATELY CALL PHYSICIAN FOR EYES, INGEST,OR
EXCESSIVE INHALE OR SKIN CONTACT.
===================== Fire Fighting Measures =====================
Extinguishing Media:N/A,NON-FLAMMABLE
Fire Fighting Procedures:SELF-CNTND BRTHG APP.(FULL PROTECTIVE
CLOTHING,IF SPILL)
Unusual Fire/Explosion Hazard:OXIDIZER.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE UNPROTECTED PERSONS.STOP LEAK. H*2O
SPRAY COOL CONT.SM SPILL:ABSORB W SAND, OR NON-COMBUSTIBLE
ABSORBENT.LG SPILL:DIKE W ABSORBENT,PUMP TO WASTE TANKS;FLUSH
RESIDUE W H*2O, FOR DISPOSAL IN FU LL ACCORD WITH REGULATIONS. DO
NOT SEWER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED,LOW
FIRE RISK AREA.PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL
CONTACT.KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:AVOID PROLONGED OR REPEATED CONTACT W CHEMICAL.REMOVE
& WASH CONTAMINATED CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MISTS/VAPORS:WEAR SELF-CNTND BRTHG APP.
Ventilation:MECHANICAL(GEN./LOCAL EXHAUST) TO ELIMINATE MIST,VAPORS
Other Protective Equipment:NORMAL FULL WORK CLOTHING COVERING
ARMS,LEGS.IMPERVIOUS.
Supplemental Safety and Health
PRODUCT IS NITRIC ACID SOLUTION (17%), MODIFIED BY ADDITION OF CHROMIC
ACID (2%). TLV FOR CHROMIC ACID SPECIFIED FOR MIXTURE. DATA BASED
UPON INTERIM DATA SHEET (1974).
================== Physical/Chemical Properties ==================
HCC:C1
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID SOLUTION; ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
PRODUCT IS ACID WITH OXIDIZING POTENTIAL.
Stability Condition to Avoid:CONTACT W COMBUSTIBLES.
Hazardous Decomposition Products:NO
==================== Disposal Considerations ====================
Waste Disposal Methods:CHROMIC ACID CONTAINING SOLUTIONS/WASTE SUBJECT
TO STRINGENT REGULATIONS.DISPOSE ONLY IN FULL REGULATORY
COMPLIANCE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CATERPILLAR 3P2044 COOLING SYS CONDITIONER
CAGE:89524
CAGE:89524
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS FOR INGREDIENTS
Fraction by Wt: 100%
===================== Hazards Identification =====================
Effects of Overexposure:MAY CAUSE IRRITATION DUE TO ALKALINITY
======================= First Aid Measures =======================
First Aid:INGESTION: DON'T INDUCE VOMITING. GIVE FLUIDS. CALL A
PHYSICIAN. SKIN/EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES.
CALL A PHYSICIAN. INHALATION: REMOVE TO FRESH AIR. TREAT
SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point:NONE <200F
Fire Fighting Procedures:NONE REQUIRED
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN WITH ABSORBANT MATERIALS
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL HANDLING OR STORAGE
PRECAUTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:GENERAL VENTILATION
Other Protective Equipment:EYEWASH/IMPERVIOUS APRON
Supplemental Safety and Health
MSDS DATE: 12/31/86. PRODUCT COMPOSED OF INORGANIC SALTS (1000201IS)
AND ORGANIC SURFACTANTS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Spec Gravity:1.13
Solubility in Water:COMPLETE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
==================== Disposal Considerations ====================
Waste Disposal Methods:NO SPECIAL METHOD
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-C-85285B, 17038 TYPE I
Kit Part:Y
CAGE:33461
CAGE:33461
============= Composition/Information on Ingredients =============
Ingred Name:BUTYL ACETATE (N-BUTYL ACETATE) *96-3*
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 10%
Other REC Limits:150 PPM
OSHA PEL:710 MG/CUM
ACGIH TLV:713 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL 3-ETHOXYPROPIONATE, PROPANOIC ACID, 3-ETHOXY-, ETHYL
ESTER *96-3*
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: 15%
Ingred Name:SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC, HIGH FLASH
AROMATIC NAPHTHA, C8&10 AROMATIC HYDROCARBON *96-3*
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: <1%
Ingred Name:2-BUTOXYETHANOL (ETHYLENE GLYCOL MONOBUTYL ETHER), BUTYL
CELLOSOLVE, BUTYL GLYCOL, GLYCOL ETHER EB * 96-3 *
CAS:111-76-2
RTECS #:KJ8575000
Other REC Limits:25 PPM (SKIN)
OSHA PEL:50 PPM (SKIN)
ACGIH TLV:25 PPM (SKIN)
Ingred Name:2-HEPTANONE, METHYL N-AMYL KETONE *96-3*
CAS:110-43-0
RTECS #:MJ5075000
Fraction by Wt: 5%
Other REC Limits:50 PPM
OSHA PEL:465 MG/CUM
ACGIH TLV:233 MG/CUM
Ingred Name:ANTI-MAR AGENT
Fraction by Wt: <1%
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *96-3*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: <0.1%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE *96-3*
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: <0.1%
Other REC Limits:100 PPM
OSHA PEL:435 MG/CUM
ACGIH TLV:434 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (IARC CARC- GROUP 3) *96-3*
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <1%
Other REC Limits:375 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:2-ETHYLHEXYL ACRYLATE, ETHYL ACRYLATE POLYMER * 96-3 *
CAS:26376-86-3
Fraction by Wt: <1%
Ingred Name:2,4-PENTANEDIONE, ACETYLACETONE * 96-3 *
CAS:123-54-6
RTECS #:SA1925000
Fraction by Wt: <5%
Ingred Name:DIETHYLENE GLYCOL BUTYL ETHER ACETATE, ETHANOL, 2-
(2-BUTOXYETHOXY), BUTYL CARBITOL ACETATE
CAS:124-17-4
RTECS #:KJ9275000
Fraction by Wt: <5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF RESPIRATORY
TRACT & NERVOUS SYSTEM DEPRESSION. SKIN: IRRITATION, SENSITIZATION.
EYES: IRRITATION. INGESTION: IRRITATION & POSSIBLE CORROSIVE ACTION
IN THE MOUTH, STOMACH TISS UE & DIGESTIVE TRACT. VOMITING MAY CAUSE
ASPIRATION, RESULTING IN CHEMICAL PNEUMONITIS.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, STAGGERING
GAIT, CONFUSION, UNCONSCIOUSNESS/COMA, SWELLING, REDNESS & RASH,
TEARING, STINGING SENSATION, DRYING, DEFATTING, CRACKING.
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE TO FRESH AIR. RESTORE BREATHING. SKIN: WASH
W/SOAP & WATER. EYES: FLUSH W/CLEAN LUKE WARM WATER FOR 15 MINS.
INGESTION: DON'T INDUCE VOMITING. NEVER GIVE ANYTHING BY MOUTH TO
AN UNCON SCIOUS PERSON. OBTAIN MEDICAL ATTENTIONIN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:23F
Lower Limits:1
Upper Limits:11
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE FULL FIRE FIGHTING EQUIPMENT W/SCBA & FULL
PROTECTIVE CLOTHING. WATER MAY BE USED TO COOL CLOSED CONTAINERS TO
PREVENT PRESSURE BUILD-UP.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE DUE TO
EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. REMOVE ALL SOURCES OF IGNITION.
VENTILATE AREA. CONTAIN & REMOVE W/INERT ABSORBENT & NON-SPARKING
TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID STORING NEAR HIGH TEMPS, FIRE,
OPEN FLAMES & SPARKING SOURCES. STORE IN TIGHTLY CLOSED CONTAINERS
IN WELL VENTILATED AREAS.
Other Precautions:KEEP CONTAINERS TIGHT & UPRIGHT. PREVENT PROLONGED
BREATHING OF VAPORS/SPRAY MISTS. AVOID CONTACT W/SKIN & EYES. DON'T
TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RECOMMENDED/APPROVED AIR PURIFYING/FRESH AIR
SUPPLIED FOR USE IN AN ORGANIC VAPOR ENVIRONMENT.
Ventilation:SUFFICIENT TO KEEP AIRBORNE CONCENTRATIONS BELOW TLV.
Other Protective Equipment:LONG SLEEVE & LONG LEGGED CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
SHIELDS.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:175-335F
Vapor Density:>1
Spec Gravity:1.30012
Evaporation Rate & Reference:(BU AC=1): 1.18
Solubility in Water:INSOLUBLE
Appearance and Odor:YELLOW LIQUID W/SOLVENT ODOR
Percent Volatiles by Volume:57.4
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS & STRONG LEWIS/MINERAL ACIDS, AMINES.
Hazardous Decomposition Products:HEAT: CO, CO2 & OXIDES OF NITROGEN.
Conditions to Avoid Polymerization:HIGH TEMPS, SPARKS/OPEN FLAMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTAINERS RETAIN PRODUCT RESIDUE. DON'T
INCINERATE CLOSED CONTAINERS. DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1 ENAMEL
CAGE:EO706
CAGE:EO706
CAGE:07708
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 32-40%
OSHA PEL:2400 MG/CUM
ACGIH TLV:750 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHANOL (ETHYL ALCOHOL), TECSOL, ALCOHOL, SYNASOL
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 5-10%
Other REC Limits:1900 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ingred Name:ETHYL 3-ETHOXYPROPIONATE, PROPANOIC ACID, 3-ETHOXY-, ETHYL
ESTER *96-1*
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: 5-10%
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 0-5%
Other REC Limits:400 PPM
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
Ingred Name:2-BUTANONE (METHYL ETHYL KETONE) (MEK)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 0-5%
Other REC Limits:590 MG/CUM
OSHA PEL:200 PPM
ACGIH TLV:590 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *96-1*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 5-10%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HYDROCARBON PROPELLANT, PETROLEUM GASES LIQUIFIED
SWEETENED, C3-7 *96-1*
CAS:68476-86-8
Fraction by Wt: 23%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NASAL & RESPIRATORY
IRRITATION, ASPHYXIATION. EYES: SEVERE IRRITATION. INGESTION: GI
IRRITATION. SKIN: IRRITATION. REPEATED/PROLONGED OVEREXPOSURE TO
SOLVENTS MAY CAUSE PERMANENT BRAIN & N ERVOUS SYSTEM DAMAGE.
INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING & INHALING THE
CONTENTS MAY BE HARMFUL/FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DIZZINESS, WEAKNESS, FATIGUE,
NAUSEA, HEADACHE, UNCONSCIOUSNESS, REDNESS, TEARING, BLURRED
VISION, VOMITING, DIARRHEA.
Medical Cond Aggravated by Exposure:RESPIRATORY &/SKIN REACTION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED.
EYES: FLUSH W/WATER FOR 15 MINS. INGESTION: DON'T INDUCE VOMITING.
ASPIRATION HAZARD. KEEP WARM & QUIET. SKIN: WASH W/SOAP &
WATER/VARIOUS H AND CLEANERS & WASH CLOTHING. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:0F
Lower Limits:1
Extinguishing Media:ALCOHOL FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE, BUT MAY BE
USED TO COOL CONTAINERS. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE. (SEE SUPP)
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE
&/AUTOIGNITE WHEN EXPOSED TO EXTREME HEAT. VAPORS ARE >THAN AIR &
MAY TRAVEL ALONG GROUND/BE MOVED & IGNITED BY IGNITION SOURCES.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. VENTILATE AREA.
ABSORB ON PAPER, VERMICULITE, FLOOR/OTHER MATERIAL & TRANSFER TO A
CLOSED CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T PUNCTURE/INCINERATE. DON'T STORE
>120F/IN DIRECT SUNLIGHT, ON/NEAR HEAT/FLAMES.
Other Precautions:STORE LARGE QUANTITIES IN BUILDING PROTECTED FOR
STORAGE OF FLAMMABLE LIQUIDS. AVOID BREATHING VAPORS/SPRAY MIST,
OPEN WINDOWS & DOORS/USE OTHER MEANS TO ENSURE FRESH AIR ENTRY
DURING APPLICATION & DR YING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR CASUAL/OCCASIONAL USE: WEAR NIOSH/MSHA
RESPIRATOR/LEAVE THE AREA.
Ventilation:FOR REGULAR/CONTINOUS USE: MECHANICAL (GENERAL) &/LOCAL
EXHAUST TO MAINTAIN EXPOSURE BELOW TLVS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:133-331F
Melt/Freeze Pt:M.P/F.P Text:>1500F
Vapor Density:>1
Spec Gravity:<1
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT TO MODERATE
Appearance and Odor:TYPICAL SOLVENT PAINT.
Percent Volatiles by Volume:80-90
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, OPEN FLAME & OTHER IGNITION SOURCES.
Hazardous Decomposition Products:BURNED: CO, CO2, VARIOUS HYDROCARBONS,
NITROGEN COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:MATERIAL COLLECTED ON ABSORBENT MATERIAL MAY BE
DEPOSITED IN A POSTED TOXIC SUBSTANCE LANDFILL IAW/FEDERAL, STATE &
LOCAL REGULATIONS. UN1950.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:7381
CAGE:JO776
CAGE:96341
CAGE:JO776
============= Composition/Information on Ingredients =============
Ingred Name:COBALT (SARA III)
CAS:7440-48-4
RTECS #:GF8750000
OSHA PEL:0.1 MG/M3;AS CO
ACGIH TLV:0.05 MG/M3;DUST 9293
================== Accidental Release Measures ==================
============= Exposure Controls/Personal Protection =============
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:A2
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:6140
CAGE:0CSJ1
CAGE:64959
CAGE:0CSJ1
============= Composition/Information on Ingredients =============
Ingred Name:KRYPTON 85
===================== Hazards Identification =====================
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
======================= First Aid Measures =======================
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
===================== Fire Fighting Measures =====================
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
================== Accidental Release Measures ==================
======================Handling and Storage ======================
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
SOURCE OF DATA-EXAM OF STOCK IN WHSE. SAFETY & HEALTH DATA DEVELOPED BY
DGSC-STF.
================== Physical/Chemical Properties ==================
HCC:A3
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-IN ACCORDANCE WITH
DOD REGULATIONS AND FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
NIIN: 01-453-0054
Product ID: HFE-7100 3M(TM) SPECIALTY LIQUID
Cage: 76381
=======================================================
Item Description Information
=======================================================
Item Manager: S9G
Item Name: CLEANING COMPOUND,SOLVENT
Specification Number: A-A-59150
Type/Grade/Class: NONE
Unit of Issue: DR
Quantitative Expression: 00000000030GL
UI Container Qty: 0
Type of Container: DRUM
=======================================================
Ingredients
=======================================================
Cas: 163702-08-7
% low Wt: 50.
% high Wt: 70.
Other REC Limits: 750 PPM TWA AIHA
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
-----------------------------
Cas: 163702-07-6
% low Wt: 30.
% high Wt: 50.
Other REC Limits: 750 PPM TWA AIHA
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50 (ORAL, RAT) > 5,000 MG/KG
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: TARGET ORGANS: NOT PROVIDED. EYE CONTACT: CONTACT WITH THE
EYES DURING PRODUCT USE IS NOT EXPECTED TO RESULT IN SIGNIFICANT IRRITATION.
SKIN CONTACT:CONTACT WITH THE SKIN DURING PRODUCT USE IS NOT EXP ECTED TO
RESULT IN SIGNIFICANT IRRITATION. INHALATION: ANIMAL STUDIES REVEALED
INCREASED LEVELS OF URINARY FLUORIDE AFTER REPEATED EXPOSURE. EXPOSURE TO
EXCESSIVE VAPOR CONCENTRATION IN CONFINED SPACE S MAY CAUSE SIGNIFICANT
INJURY. INGESTION: INGESTION IS NOT A LIKELY ROUTE OF EXPOSURE TO THIS
PRODUCT.
Explanation Of Carcinogenicity: NONE
First Aid: EYE CONTACT: IMMEDIATELY FLUSH EYES WITH LARGE AMOUNT OF WATER. GET
MEDICAL ATTENTION. SKIN CONTACT: WASH AFFECTED AREA WITH SOAP AND WATER.
INHALATION: IF SIGNS/SYMPTOMS OCCUR, REMOVE PERSON TO FRESH AIR. IF
SIGNS/SYMPTOMS CONTINUE, CALL APHYSICIAN. IF SWALLOWED: NO NEED FOR FIRST AID
IS ANTICIPATED. THIS PRODUCT IS NOT EXPECTED TO BE IRRITATING TO THE EYES,
SKIN OR RESPIRATORY SYSTEM AT ROOM TEM PERATURES. THIS ASSESSMENT DOES NOT
ACCOUNT FOR CONTAMINANTS FROM PRODUCT USE. THE SUGGESTED FIRST AID MEASURES
ARE BASIC FIRST AID FOR REMOVAL OF FOREIGN MATERIALS FROM EYES AND/OR SKIN.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: OBSERVE PRECAUTIONS FROM OTHER SECTIONS. VENTIALTE
AREA. CONTAIN SPILL. COVER WITH ABSORBENT MATERIAL. COLLECT SPILLED MATERIAL.
CLEAN UP RESIDUE WITH AN APPROPRIATE ORGANIC SOLVENT. READ AND FOLLOW S AFETY
PRECAUTIONS ON THE SOLVENT LABEL AND MSDS. PLACE IN METAL CONTAINER. SEAL THE
CONTAINER.IN CASE OF SIGNIFICANT SPILLS IN CONFINED AREA, WARN OTHERS AND
LEAVE IMMEDIATELY.
Waste Disposal Methods: AS A DISPOSAL ALTERNATIVE, INCINERATE IN PRESENCE OF A
COMBUSTIBLE MATERIAL IN AN INDUSTRIAL OR COMMERCIAL FACILITY CAPABLE OF
HANDLING HALOGENATED WASTE. DISPOSE OF COMPLETELY ABSORBED WASTE PRODUCT IN
A HAZARDOUS WASTE FACILITY. RECLAIM IF FEASIBLE. FOR INFORMATION ON PRODUCT
RETURN, CONTACT YOURDISTRIBUTOR.
Handling And Storage Precautions: STORE UNDER NORMAL WAREHOUSE CONDITIONS.
Other Precautions: NO SMOKING: SMOKING WHILE USING THIS PRODUCT CAN RESULT IN
CONTAMINATION OF THE TOBACCO AND/OR SMOKE AND LEAD TO THE FORMATION OF THE
HAZARDOUS DECOMPOSITION PRODUCTS.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: NONE
Autoignition Temp: =405.C, 761.F
Lower Limits: NONE
Upper Limits: NONE
Extinguishing Media: NONFLAMMABLE. KEEP CONTAINERS COOL WITH WATER SPRAY WHEN
EXPOSED TO FIRE TO AVOID RUPTURE.
Fire Fighting Procedures: WHEN FIRE FIGHTING CONDITIONS ARE SEVERE AND TOTAL
THERMAL DECOMPOSITION OF PRODUCT IS POSSIBLE, WEAR FULL PROTECTIVE CLOTHING,
INCLUDING HELMET, NIOSH-APPROVED SELF-CONTAINED, POSITIVE PRESSURE BREA
THING APPARATUS, BUNKER COAT, PANTS, BANDS AROUND ARMS, WAIST AND LEGS, FACE
MASK AND COVERING FOR EXPOSED AREAS OF HEAD
Unusual Fire/Explosion Hazard: EXTREME CONDITIONS OF HEAT (WELDING, OPEN FLAME,
MISUSE, OR EQUIPMENT FAILURE) MAY PRODUCE DECOMPOSITION PRODUCTS THAT INCLUDE
HYDROGEN FLUORIDE. NO SMOKING.
=======================================================
Control Measures
=======================================================
Respiratory Protection: AVOID BREATHING OF VAPORS, MISTS OR SPRAY. SELECT ONE
OF THE FOLLOWING NIOSH APPROVED RESPIRATORS BASED ON AIRBORNE CONCENTRATION
OF CONTAMINANTS AND IN ACCORDANCE WITH OSHA REGULATIONS. HALF-MASK SUP PLIED
AIR RESPIRATOR, FULL-FACE SUPPLIED AIR RESPIRATOR.
Ventilation: USE IN WELL VENTILATED AREA. PROVIDE SUFFICIENT VENTILATION TO
MAINTAIN EMISSIONS BELOW RECOMMENDED EXPOSURE LIMITS.
MATERIAL.
Other Protective Equipment: EYE BATH, WASHING FACILITY, LAB COAT OR UNIFORM.
Work Hygienic Practices: DO NOT EAT, DRINK OR SMOKE WHEN USING THIS PRODUCT.
WASH EXPOSED AREAS THOROUGHLY WITH SOAP AND WATER. INGESTION IS NOT AN
EXPECTED ROUTE OF EXPOSURE.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
Boiling Point: =60.C, 140.F
Melt/Freeze Pt: =-135.C, -211.F
Vapor Pres: 163MMHG @ 20C/68F
Vapor Density: 8.6 AIR=1
Spec Gravity: 1.5G/ML
Viscosity: 0.6 CENTIPOISE@23C
Evaporation Rate & Reference: N/D
Appearance and Odor: CLEAR, COLORLESS, LIQUID. SLIGHT ETHEREAL ODOR.
Percent Volatiles by Volume: 100%
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: AVOID EXPOSURE TO TEMPERATURES ABOVE THE BOILING
POINT. AVOID EXCEEDING A WATT DENSITY OF 50 WATTS/INCH2 FROM A HEATER
SURFACE.
Materials To Avoid: STRONG ACIDS, STRONG BASES, STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: HYDROGEN FLUORIDE, CARBON DIOXIDE,
ISO-PERFLUOROBUTYRIC ACID, CF3COOH, N-PERFLUOROBUTYRIC ACID
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
Toxicological Information: ACUTE INHALATION LETHAL CONCENTRATION: >100,000
PPM (RAT, 4-HOUR). PRACTICALLY NON-TOXIC BY INGESTION. 90 DAY INHALATION
STUDY IN RATS: NOEL = 7500 PPM. NOT A SIGNIFICANT ROUTE OF EXPOSURE BY DERMAL
A BSORPTION.
=======================================================
Ecological Information
=======================================================
Ecological: ZERO OZONE DEPLETION POTANTIAL. AQUATIC TOXICITY: 96-HR LC50
FATHEAD MINNOW = > 7.9 MG/L 48-HR EC50 FOR WATER FLEA (DAPHNIA MAGNA)
=> 10 MG/L. 96-HR ERC50 (GROWTH) FOR ALGAE = > 8.9 MG/L
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: EPCRA 311/312 RQ: NOT REPORTABLE.
Federal Regulatory Information: THE U.S. ENVIRONMENTAL PROTECTION AGENCY (EPA)
HAS LISTED 3M HFE-7100 AS AN ACCETABLE SUBSTITUTE FOR OZONE DEPLETING
SUBSTANCES IN SPECIFIC SOLVENT CLEANING AND AEROSOL INDUSTRY APPLICATIONS
UNDER ITS SIGNIFICANT NEW ALTERNATIVES PROGRAM (SNAP). THE COMPONENTS OF
THIS PRODUCT ARE IN COMPIANCE WITH THE CHEMICAL NOTIFICATION REQUIREMENTS OF
TOXIC SUBSTANCE CONTROL ACT (TSCA).
=======================================================
Transportation Information
=======================================================
Trans ID NO: 147445
Product ID: HFE-7100 3M(TM) SPECIALTY LIQUID
Review Date: 08/21/1999
Net Unit Weight: 375 LBS
Multiple KIT Number: 0
Unit Of Issue: DR
Container QTY: 0
Type Of Container: DRUM
Additional Data: NOT REGULATED, ALL TRANSPORTATION MODES, PER MSDS.
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: HFE-7100 3M(TM) SPECIALTY LIQUID
Cage: 76381
Company Name: MINNESOTA MINING AND MFG CO, DBA 3M
Street: 3M CENTER BLDG 224-5S-04
Zipcode: 55144-1000
Label Required IND: Y
Date Of Label Review: 08/21/1999
Status Code: A
Label Date: 04/09/1999
Year Procured: 1999
Origination
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: NO
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: TARGET ORGANS: NOT PROVIDED. EYE CONTACT: CONTACT WITH
THE EYES DURING PRODUCT USE IS NOT EXPECTED TO RESULT IN SIGNIFICANT
IRRITATION. SKIN CONTACT:CONTACT WITH THE SKIN DURING PRODUCT USE IS NOT EXP
ECTED TO RESULT IN SIGNIFICANT IRRITATION. INHALATION: ANIMAL STUDIES
REVEALED INCREASED LEVELS OF URINARY FLUORIDE AFTER REPEATED EXPOSURE.
EXPOSURE TO EXCESSIVE VAPOR CONCENTRATION IN CONFINED SPACE S MAY CAUSE
SIGNIFICANT INJURY. INGESTION: INGESTION IS NOT A LIKELY ROUTE OF EXPOSURE
TO THIS PRODUCT.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-P-24441/20 F-150 TYPE III GREEN COMP A, 3173800
Kit Part:Y
Preparer's Name:ERNEST CARTER
CAGE:55849
CAGE:55849
============= Composition/Information on Ingredients =============
Ingred Name:TALC
CAS:14807-96-6
RTECS #:WW2710000
< Wt:40.
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:2 MG/M3
Ingred Name:BUTYL ALCOHOL
CAS:71-36-3
RTECS #:EO1400000
< Wt:25.2
OSHA PEL:300 MG/M3;100 PPM
ACGIH STEL:C152 MG/M3;C50 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:POLYAMIDE ADDUCT RESIN
< Wt:20.
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
< Wt:10.
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:MAGNESIUM SILICATE
< Wt:10.
Ingred Name:IRON OXIDE YELLOW
CAS:51274-00-1
< Wt:5.
Ingred Name:AMIDO AMINE RESIN
CAS:68443-08-3
Code:F
< Wt:5.
Ingred Name:XYLENE
CAS:1330-20-7
RTECS #:ZE2100000
< Wt:1.4
ACGIH TLV:434 MG/M3;100 PPM
ACGIH STEL:651 MG/M3;150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: SEVERE IRRITANT. SEVERE BURNS.
SENSITIZER. CAN BE ABSORBED THROUGH SKIN. CAN CAUSE DEFATTING AND
DRYING OF SKIN. INHALATION: SEVERE IRRITANT. DELAYED LUNG INJURY.
CENTRAL NERVOUS SYSTEM DAMAGE. CHEMICAL PNEUMONIA. XYENE OR
TOLUENE MAY CAUSE IRREGULAR HEART BEAT. REPEATED EXPOSURE TO IRON
DUST CAN CAUSE SIDEROSIS. EYES: SEVERE IRRITANT. IRREVERSIBLE BURNS
AND DAMAGE. INGESTION: HARMFUL IF SWA LLOWED. ASPIRATION INTO LUNGS
CAN DAMAGE LUNGS AND CAUSE CHEMICAL PNEUMONIA.
Effects of Overexposure:VAPOR OR SPRAY MIST OR SPATTERED MATERIAL CAN
BE HARMFUL. IRRITATING TO EYES, SKIN, AND IF INHALED; TO NOSE AND
THROAT. EXCESSIVE OR PROLONGED INHALATION CAN CAUSE HEADACHJE,
NAUSEA OR DIZZINESS. REP EATED AND PROLONGED OCCUPATIONAL
OVEREXPOSURE TO SOLVENTS IS ASSOCIATED WITH PERMANENT BRAIN AND
NERVOUS SYSTEM DAMAGE. INTENTIONAL ABUSE, MIUSE OR OTHER MASSIVE
EXPOSURE TO SOLVENTS MAY CAUSE MULTIPL E ORGAN DAMAGE AND/OR DEATH.
OVER-EXPOSURE (PROLONGED OR REPEATED USE): CAN AGGRAVATE OR
ACCENTUATE ANY OF THESE EFFECTS. TARGET ORGANS: KIDNEYS. LIVER.
BLOOD. LUNGS. HEART. SKIN. EYES. STOMACH. CENTR AL NERVOUS SYSTEM.
FETAL DEFECTS.
Medical Cond Aggravated by Exposure:KIDNEYS. LIVER. SKIN. EYES.
RESPIRATORY. ALLERGIES. LUNGS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE NORMAL BREATHING.
TREAT SYMPTOMATICALLY. SEE PHYSICIAN. SKIN: WASH THOROUGHLY WITH
SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. CONSULT PHYSICIAN IF
IRRITATI ON PERSISTS. EYES: FLUSH IMMEDIATELY WITH PLENTY OF WATER
FOR AT LEAST 15 MINUTES AND GET MEDICAL ATTENTION. INGESTION: DRINK
1 OR 2 GLASSES OF WATER TO DILUTE. NEVER GIVE ANYTHING BY MOUTH TO
AN UNCO NSCIOUS PERSON. DO NOT INDUCE VOMITNG (UNLESS METHANOL;
LISTED IN SECTION 2). CONSULT PHYSICIAN OR POISON CONTROL CENTER
IMMEDIATELY. TREAT SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:=35.6C, 96.F
Lower Limits:1.0%
Upper Limits:11.2%
Extinguishing Media:FOAM CO2 DRY CHEMICAL.
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT, SELF CONTAINED
BREATHING APPARATUS. WATER MAY BE USED TO COOL CONTAINERS TO
PREVENT PRESSURE BUILD UP OR EXPLOSION WHEN EXPOSED TO EXTREME
HEAT.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT AND PRESSURE BUILDUP. MAY PRODUCE A
FLOATING FIRE HAZARD. ISOLATE FROM ELECTRICAL EQUIPMENT, SPARKS,
HEAT AND OPEN FLAME.VAPORS MAY SPREAD LO NG DISTANCES, CAUSE FLASH
FIRE OR IGNITE EXPLOSIVELY.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
BREATHING VAPORS. VENTILATE AREA. USE ABSORBENT, INERT CLEANUP
MATERIALS. (DO NOT USE SAWDUST.) REMOVE ABSORBENT MATERIAL WITH
NON-SPARKING TOOLS. PLACE IN SEPARA TE CONTAINER. KEEP OUT OF
SEWERS AND WATERWAYS. IF ENTRY IS THREATENED OR OCCURS, NOTIFY
LOCAL AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED, UPRIGHT WHEN
NOT IN USE. STORE IN COOL, DRY, WELL VENTILATED AREA. AVOID
PROLONGED STORAGE TEMPERATURES ABOVE 100 F. USE CAUTION WHEN
POURING. AVOID BREATHING SANDING DUST. DO N OT WELD OR FLAME CUT ON
EMPTY CONTAINER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA CERTIFIED RESPIRATOR DESIGNED TO
REMOVE A COMBINATION OF PARTICULATES (DUST OR SPRAY MIST) AND
VAPOR. WHEN BRUSHING, ROLLING OR SPREADING; SELECT THE APPROPRIATE
RESPIRATORY PROTECTION FOR THE CONDITIONS. FOR SPECIFIC
CONDITIONS, REFER TO CURRENT "NIOSH POCKET GUIDE TO CHEMICAL
HAZARDS". IN CONFINED OR RESTRICTED VENTILATION AREAS USE AIR LIN
Ventilation:IMPLEMENT ADMINISTRATIVE AND ENGINEERING CONTROLS TO REDUCE
EXPOSURE. PROVIDE SUFFICIENT VENTILATION IN VOLUME AND PATTERN TO
KEEP AIR CONTAMINANT CONCENTRATIO
TO PREVENT SKIN CONTACT.
FACE SHIELD TO PROTECT EYE
Other Protective Equipment:DEPENDENT UPON APPLICATION METHOD.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING, SMOKING OR USING TOILET. LAUNDER CONTAMINATED CLOTHING
BEFORE USE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:244-276 F
Vapor Density:HEAVIER
VOC Pounds/Gallon:339
Evaporation Rate & Reference:IS SLOWER THAN BUTYL
Solubility in Water:NO
Appearance and Odor:LIQUID SOLVENT.
Percent Volatiles by Volume:47.24
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS AND ALKALIES.
Stability Condition to Avoid:HEAT, OPEN FLAME, ARC OR SPARKS. EPOXIES
UNDER UNCONTROLLED CONDITIONS.
Hazardous Decomposition Products:(BY FIRE, BURNING OR WELDING); CO,
CO2.NOX. IRON OXIDE FUMES. TOXIC GASES OR FUMES.
Conditions to Avoid Polymerization:WILL NOT OCCUR UNDER NORMAL
CONDITIONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE IN SEPARATE, APPROPRIATE, CLOSED CONTAINER
IN ACCORDANCE WITH ALL APPLICABLE LOCAL, STATE, AND FEDERAL
REGULATIONS. THIS MATERIAL HAS NOT BEEN TESTED BY TOXICITY
CHARACTERISTIC LEACHING PROCEDUR E (TCLP).
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PAINT STRIPPER 7 MIL-R-81294C
CAGE:77513
CAGE:77513
============= Composition/Information on Ingredients =============
Ingred Name:METHYLENE CHLORIDE(SARA III)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: < 37%
OSHA PEL:500 PPM/C,1000; Z2
ACGIH TLV:50 PPM, A2; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SODIUM CHROMATE (SARA III)
CAS:7775-11-3
RTECS #:GB2955000
Fraction by Wt: < 2%
OSHA PEL:0.1 PPM CRO3;CEILING
ACGIH TLV:0.05 MG CR/M3; 9192
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:PHENOLIC BODIES
Fraction by Wt: < 16%
ACGIH TLV:5 PPM (SKIN)
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Explanation of Carcinogenicity:METHYLENE CHLORIDE AND HEXAVALENT
CHROMATES ARE LISTED AS CARCINOGENS.
Effects of Overexposure:IRRITATION OF NOSE AND EYES, SLIGHT NARCOSIS.
======================= First Aid Measures =======================
First Aid:SKIN: WASH WITH SOAP AND WATER. EYES: FLUSH WITH WATER,
OBTAIN MEDICAL ATTENTION
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:NONE
Extinguishing Media:CARBON DIOXIDE OR CHEMICAL FOAM.
Fire Fighting Procedures:THERMAL DECOMPOSITION WILL PRODUCE TOXIC
OXIDES OF CHLORINE, WEAR GAS MASKS.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. MOP UP SPILLAGE OR FLUSH TO
SEWER WITH WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:TRANSPORT AND STORE IN CLOSED
CONTAINERS AT TEMP- ERATURES UP TO 110 F.
Other Precautions:DO NOT STORE IN DIRECT RAYS OF SUN AND OPEN
CONTAINERS CAREFULLY TO AVOIDSPURTING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FRESH AIR MASK
Ventilation:LOCAL EXHAUST
Other Protective Equipment:SOLVENT RESISTANT APRONS
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:110 F
Melt/Freeze Pt:M.P/F.P Text:80%
Vapor Pres:350 MM HG
Vapor Density:>1 (AIR=1)
Spec Gravity:1.10 (H2O=1)
Evaporation Rate & Reference:>1 (BUTYL ACETATE=1)
Solubility in Water:APPRECIABLE
Appearance and Odor:VISCOUS YELLOW LIQUID PHENOLIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZERS.
Hazardous Decomposition Products:THERMAL DECOMPOSITION WILL PRODUCE
TOXIC OXIDES OF CHLORINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:TREAT FOR PHENOLIC BODIES AND CHROMATE OR HAUL
TO LIQUID DUMP.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:92-823093A 30
CAGE:5S187
CAGE:5S187
CAGE:88907
============= Composition/Information on Ingredients =============
Ingred Name:ADDITIVES PACKAGE
Fraction by Wt: 10%
Ingred Name:OIL PETROLEUM DISTILLATES, SOLVENT-DEWAXED HEAVY PARAFFINIC
CAS:64742-65-0
RTECS #:PY8038500
Fraction by Wt: 80%
Other REC Limits:5 MG/CUM
Ingred Name:VISCOSITY INDEX IMPROVER
Fraction by Wt: 10%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MISTS >TLV MAY CAUSE
CHEMICAL PNEUMONITIS. SKIN/EYES: MILD IRRITANT. INGESTION: LOW
TOXICITY. RISK OF ASPIRATION INTO LUNGS. INGESTION OF LARGE
QUANTITIES MAY CAUSE GASTROINTESTINAL DISCOM FORT. SMALL DOSES MAY
PRODUCE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DIARRHEA, HEADACHE
Medical Cond Aggravated by Exposure:NONE EXPECTED
======================= First Aid Measures =======================
First Aid:INHALATION: IMMEDIATELY MOVE TO FRESH AIR. IF BREATHING HAS
STOPPED, GIVE CPR. IF BREATHING IS DIFFICULT, GIVE HUMIDIFIED
OXYGEN. EYES: FLUSH W/LARGE AMOUNTS OF WATER FOR 15 MINS. SKIN:
WASH W/SOAP & WATER FOR 15 MINS. INGESTION: DON'T INDUCE VOMITING.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:392F
Extinguishing Media:CO2, DRY CHEMICAL, FOAM/WATER FOG
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:WATER MAY CAUSE FROTHING.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: REMOVE ALL SOURCES OF HEAT/IGNITION,
PROVIDE ADEQUATEVENTILATION. CONTAIN LEAK W/ABSORBENT, INERT,
NON-COMBUSTIBLE ,MATERIAL. LARGE: CONTAIN & TRANSFER TO SECURE
CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:PRODUCT IS A COMBUSTIBLE LIQUID. KEEP
AWAY FROM HEAT & FLAMES. STORE <150F. DON'T APPLY TO HIGH
HEAT/FLAME TO CONTAINER.
Other Precautions:KEEP AWAY FROM STRONG OXIDIZING AGENTS. EMPTY
CONTAINERS MAY CONTAIN PRODUCT RESIDUE WHICH COULD INCLUDE
FLAMMABLE/EXPLOSIVE VAPORS. KEEP AWAY FROM CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF HIGH VAPOR/MIST CONCENTRATIONS ARE EXPECTED,
USE APPROPRIATE NIOSH APPROVED RESPIRATOR FOR ORGANIC VAPOR &
MISTS.
Ventilation:LOCAL: TO MAINTAIN EXPOSURE LEVELS BELOW RECOMMENDED
EXPOSURE LIMITS. MECHANICAL: IN CONFINED SPACES.
Other Protective Equipment:WEAR BODY-COVERING CLOTHES
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:665F
Vapor Density:>1
Spec Gravity:0.88
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER, OILY LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS
Stability Condition to Avoid:HEAT, FLAME
Hazardous Decomposition Products:CO2/CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TRIG-A-CAP MARKING PAINT ETNC2D, SUPERSTRIPE(SUPDAT)
CAGE:1BF99
CAGE:1BF99
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENT NAPHTHA; (PETROLEUM SOLVENT NAPHTHA, HEAVY
AROMATIC)
CAS:64742-94-5
RTECS #:WF3100000
Fraction by Wt: <1.0%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 5-15%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 10-20%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT
Ingred Name:TOLUENE (SARA 313) (CERCLA)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 12-16%
OSHA PEL:200 PPM; Z-2
ACGIH TLV:50 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PROPANE, 2-METHYL-; (ISOBUTANE)
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 15-20%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SOLVENT NAPTHA (PETROLEUM), LIGHT ALIPHATIC; (PETROLEUM
SOLVENT NAPHTHA(LIGHT ALIPHATIC))
CAS:64742-89-8
Fraction by Wt: 20-25%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MAY CAUSE IRRIT, REDNESS,
TEARING, BLURRED VISION & CONJUNCTIVITIS. SKIN: PRLNGD/RPTD CONT
MAY CAUSE MOD IRRIT & DEFATTING DERM. INHAL: EXCESS INHAL OF VAPS
MAY CAUSE HDCHS, NAUS, DROW & IRRIT O F MUC MEMB OF NOSE & THROAT.
INGEST: MAY CAUSE NAUSEA. NOTE: TOLUENE APPEARS ON THE NAVY LISTING
OF (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: OCCUPATIONAL CHEMICAL REPRODUCTIVE
HAZARDS. SEEK CONSULTATION FROM APPROPRIATE HEALTH PROFESSIONALS
CONCERNING LATEST HAZARD LIST INFORMATION AND SAFE HANDLING &
EXPOSURE INFORMATION .
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MINS, LIFTING UPPER &
LOWER LIDS OCCAS, OBTAIN MED ATTN. SKIN: WASH CONTAMD AREA THORO
W/SOAP & WATER. APPLY MOISTURIZING HAND CREAM. INHAL: REMOVE TO
FRESH AIR. IF BRTHG IS DFCLT, ADMIN O*2 ONLY IF TRAINED, IF BRTHG
HAS STOPPED GIVE ARTF RESP, PREF MOUTH-TO-MOUTH, KEEP PERS WARM,
QUIET & OBTAIN MED ATTN. INGEST: ONLY INDUCE VOMIT AT INSTRUCTION
OF MD. (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:-40F,-40C
Lower Limits:1.0%
Upper Limits:8.5%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
WATER MAY BE USED TO COOL CLSD CNTNRS TO PVNT PRESS BUILD-UP & POSS
EXPLOSION WHEN EXPOSED TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:SPRAY MIST OR VAPORS FROM CAN PER 400
CUBIC FEET OF AIR MAY REACH LOWER EXPLOSIVE LIMIT & COULD BE
IGNITED BY A FLAME SPARK.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION, VENTILATE
AREA, WIPE UP W/INERT MATERIAL. DO NOT FLUSH INTO DRAINS. REMOVE
RESIDUE W/SUITABLE SOLVENT CLEANER IMMEDIATELY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE AT TEMP >120F. EXPOSURE
TO HIGH TEMPERATURES MAY CAUSE BURSTING. AVOID STORING NEAR
RADIATOR, STOVE, OPEN FLAME OR DIRECT SUNLIGHT.
Other Precautions:DO NOT INCINERATE OR PUNCTURE CAN. CONTENTS UNDER
PRESSURE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY NEEDED IF LOCAL EXHAUST IS
SATISFACTORY. IF VENTILATION IS INADEQUATE, USE NIOSH/MSHA APPRVD
RESPIRATORY MASK FOR PROTECTION AGAINST SPRAY MIST.
Ventilation:REQUIREMENTS VARY W/RATE OF PROD USE. SUPPLEMENT VENT TO
KEEP BELOW OSHA & ACGIH PERMISSIBLE LEVELS OF EACH INGREDIENT.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA.
Work Hygienic Practices:WHEN USING THIS PRODUCT, DO NOT EAT, DRINK OR
SMOKE.
Supplemental Safety and Health
TRADENAME/PART #:ATHLETIC PAINT. SPEC GRAV: 0.86-0.958. MATL TO AVOID:
METALS AND THEIR ALLOYS SUCH AS MAGNESIUM. FIRST AID PROC: KEEP
PERSON WARM, QUIET AND OBTRAIN MED ATTN. NOTE: FOLLOWING AN Y FIRST
AID, MEDICAL ADVICE SHOULD BE OBTAINED, ESPECIALLY IF SYMPTOMS
PERSIST.
================== Physical/Chemical Properties ==================
Vapor Density:HVR/AIR
Spec Gravity:SUPDAT
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:70
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ALKALI & ALKALINE EARTH MTLS SUCH AS SODIUM,
POTASSIUM & BARIUM. FINE POWDERS OF LIGHT(SUPDAT)
Stability Condition to Avoid:HEAT, SPARKS & FIRE.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CO,
CO*2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL LAWS. DO NOT PIERCE OR BURN CAN EVEN AFTER USE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:P/N 22-7692 ETCHING SOLUTION QUART
CAGE:EO331
CAGE:EO331
CAGE:1B236
============= Composition/Information on Ingredients =============
Ingred Name:FERRIC CHLORIDE (CERCLA)
CAS:7705-08-0
RTECS #:LJ9100000
Fraction by Wt: 32-45%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG (FE)/M3
ACGIH TLV:1 MG (FE)/M3; 9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HYDROGEN CHLORIDE (HYDROCHLORIC ACID) (SARA 302/313)
(CERCLA)
CAS:7647-01-0
RTECS #:MW4025000
Fraction by Wt: <3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 5 PPM
ACGIH TLV:C 5 PPM; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:FERROUS CHLORIDE (CERCLA)
CAS:7758-94-3
RTECS #:NO5400000
Fraction by Wt: <0.5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG (FE)/M3
ACGIH TLV:1 MG (FE)/M3; 9596
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS 900 MG/M3
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION OF CONCENTRATED VAPOR OR
MIST MAY CAUSE IRRITATION OF THE RESPIRATORY TRACT. CONTACT MAY
CAUSE SKIN & EYE IRRITATION OR BURNS. INGESTION MAY CAUSE SEVERE
LIVER &/OR KIDNEY DAMAGE; MAY BE FA TAL.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:SKIN-IRRITATION, BURNS. EYES-IRRITATION,
TEARING, EYE TISSUE DISCOLORATION. INHALATION-IRRITATION OF
RESPIRATORY TRACT. INGESTED-SEVERE LIVER &/OR KIDNEY DAMAGE, DEATH.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:IN ALL CASES GET MEDICAL IMMEDIATE ATTENTION. EYES-FLUSH WITH
WATER FOR 15 MINUTES, LIFT LIDS. SKIN-REMOVE CONTAMINATED CLOTHES.
WASH WITH MILD SOAP & WATER. INHALED-REMOVE TO FRESH AIR. GIVE
OXYGEN O R ARTIFICIAL RESPIRATION AS NEEDED. INGESTED-IF CONSCIOUS,
GIVE LOTS OF WATER. DO NOT INDUCE VOMITING!
===================== Fire Fighting Measures =====================
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, DRY CHEMICAL, FOAM
OR OTHER AGENTS AS APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL FIRE FIGHTER'S PROTECTIVE GEAR AS APPROPRIATE FOR SURROUNDING
FIRE. USE WATER TO COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:MAY RELEASE CHLORINE GAS AT ELEVATED
TEMPERATURES.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL IN ORDER TO PREVENT
CONTAMINATION OF WATERWAYS. NEUTRALIZE WITH LIME OR SODA ASH. FLUSH
WITH WATER IN ACCORDANCE WITH APPLICABLE REGULATIONS TO WASTE
TREATMENT SYSTEM.
Neutralizing Agent:LIME OR SODA ASH.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE AWAY FROM
STRONG ALKALIS AND ALKALI METALS. KEEP CONTAINERS CLOSED & DRY.
PROTECT CONTAINERS FROM PHYSICAL DAMAGE.
Other Precautions:USE HANDLING EQUIPMENT WITH PRODUCT (PVC, TEFLON,
RUBBER, FRP, TITANIUM, POLYPROPYLENE OR POLYETHYLENE). WASH
THOROUGHLY AFTER HANDLING. EMPTIED CONTAINER MAY RETAIN VAPOR &
RESIDUE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE
OR AN EMERGENCY OCCURS; WEAR AN MSHA/NIOSH APPROVED RESPIRATOR OR
AN AIR-SUPPLIED RESPIRATOR OR SCBA, AS REQUIRED. USE IAW
MANUFACTURER'S INSTRUCTION AN D 29 CFR 1910.134.
Ventilation:GOOD GENERAL VENTILATION.
Other Protective Equipment:RUBBER FOOTWEAR, ACID RESISTANT HOOD & FULL
BODY SUIT AS APPROPRIATE. EYE WASH STATION & SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
DO NOT WEAR CONTACT LENSES WHEN HANDLING THIS PRODUCT. SARA/TITLE III
CATAGORIES: IMMEDIATE (ACUTE) HEALTH HAZARD. MSDS PRESENTED BY CAGE
1B236 FOR SOLICITATION/CONTRACT NUMBER: MDA414-97-PC179.
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:230F,110C
Melt/Freeze Pt:M.P/F.P Text:-58F,-50C
Vapor Pres:NEGLIGIBLE
Spec Gravity:1.432
pH:<2.0
Evaporation Rate & Reference:>1.0 (METHOD NOT GIVEN)
Solubility in Water:COMPLETE
Appearance and Odor:REDDISH BROWN LIQUID; IRON/ACID ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG ALKALIS AND ALKALI METALS.
Stability Condition to Avoid:MATERIAL IS ACIDIC & CORRODES MOST METALS.
Hazardous Decomposition Products:MAY RELEASE CHLORINE GAS AT ELEVATED
TEMPERATURES.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF SPILLED, NEUTRALIZED OR WASTE
PRODUCT, CONTAMINATED SOIL & OTHER CONTAMINATED MATERIALS IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:VICTOCOR 200
CAGE:22968
CAGE:79150
CAGE:22968
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS-CHRYSOTILE
RTECS #:GC2625000
Fraction by Wt: 40%
ACGIH TLV:2 F/CC
Ingred Name:NITRILE RUBBER COMPOUND
Fraction by Wt: 6%
ACGIH TLV:NONE
===================== Hazards Identification =====================
Effects of Overexposure:ASBESTOS EXPOSURE CAN CAUSE ASBESTOSIS,LUNG
CANCER & MESOTHELIOMA
======================= First Aid Measures =======================
First Aid:INHALATION:MOVE TO FRESH AIR,BEGIN CPR IF BREATHING HAS
STOPPED,EYE CONTACT:FLUSH W/WATER FOR 15 MINUTES,SEEK MEDICAL
ATTENTION,SKIN CONTACT:WASH W/SOAP & WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER,CO*2,DRY CHEMICAL
Fire Fighting Procedures:USE PRESSURE-DEMAND SCBA FOR FIREFIGHTING
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID DRY SWEEPING,USE VACUUM OR WET
METHODS,IF MATERIAL IS ABRADED,USE HEPA FILTRATION ON VACUUM
EXHAUST
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE & STORE TO MINIMIZE
ABRASION,STORE IN COOL, DRY, LOCATION
============= Exposure Controls/Personal Protection =============
Respiratory Protection:HALF-FACE HEPA MECHANICAL FILTER FOR <10 TIMES
TLV (<20F/CC)
Ventilation:PROVIDE LEV TO MAINTAIN EXPOSURES BELOW TLV
Other Protective Equipment:NONE NORMALLY REQUIRES
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:T6
Appearance and Odor:SOLID-NEGLIGIBLE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:FIRE,HIGH TEMPERATURES
Hazardous Decomposition Products:HYDROGEN CYANIDE,CO,CO*2,HYDROGEN
SULFIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT DPDD FOR DISPOSAL INFORMATION
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:METHYL ALCOHOL, A433S-20
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:METHANOL; (METHYL ALCOHOL) (SARA 313) (CERCLA)
CAS:67-56-1
RTECS #:PC1400000
OSHA PEL:200 PPM, S
ACGIH TLV:200PPM/250STEL, S
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SUP DAT: DIHYDRIDE, CARBON TETRACHLORIDE + METALS,
CHLOROFORM + HEAT, CHLOROFORM + SODIUM HYDROXIDE, CYANURIC (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2: CHLORIDE, DIETHYL ZINC, NITRIC ACID, & POTASSIUM
TERTBUTOXIDE. PLEASE REFER TO THE NFPA FIRE PROTECTION (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3: GUIDE FOR ALL SPECIFICS.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP: CHRONIC INHALATION & INGESTION MAY CAUSE
EFFECTS SIMILAR TO THOSE OF ACUTE INHALATION & INGESTION.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: INDUCE VOMIT BY GIVING 1 TEASPOON OF SYRUP
OF IPECAC. INHAL: GET MED AID IMMED. REMOVE FROM (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: EXPOS TO FRESH AIR IMMED. IF NOT BRTHG, GIVE ARTF
RESP. IF BRTHG IS DFCLT, GIVE OXYGEN. NOTES TO MD: (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: SYMPS MAY BE DELAYED. METABOLISM OF MEOH CAN BE
PREVENTED BY ADMIN OF ETOH BY QUALIFIED MED PERS. (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: NO SPECIFIC ANTIDOTE EXISTS.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: AWAY FROM INCOMPATIBLE SUBSTANCES.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT): 5628 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: KIDNEYS, CNS, LIVER,
CARDIOVASCULAR SYS, EYES. ACUTE: EYES: MOD IRRIT. VAPS MAY CAUSE
IRRIT. MAY CAUSE PAINFUL SENSIT TO LIGHT. SKIN: MAY CAUSE IRRIT.
MAY BE ABSORBED THRU SKIN IN HARMF UL AMTS. INGEST: MAY CAUSE IRRIT
OF DIGESTIVE TRACT, RESP FAILURE, VASCULAR COLLAPSE & DMG, KIDNEY
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: FAILURE. INHAL: MAY CAUSE RESP TRACT
IRRIT, LIVER & KIDNEY DMG. MAY CAUSE ADVERSE CNS EFTS INCL HDCH,
CONVLS, & POSS DEATH. MAY CAUSE VISUAL IMPAIRMENT & POSS PERM
BLINDNESS. MAY CAUSE EFTS SIMILAR TO THOSE DESCRIBED FOR INGEST.
CHRONIC: PRLNG/RPTD SKIN CONT CAN CAUSE DERM. (ING 5)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN, OCCAS
LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. DO NOT ALLOW VICTIM
TO RUB EYES/KEEP EYES CLSD. SKIN: FLUSH W/PLENTY OF SOAP & WATER
FOR AT LEAS T 15 MIN WHILE REMOVING CONTAM CLTHG & SHOES. GET MED
AID IF IRRIT DEVELOPS/PERSISTS. INGEST: IF VICTIM IS CONSCIOUS &
ALERT, GIVE 2-4 CUPFULS OF MILK/WATER. GET MED AID IMMED. (ING 6)
===================== Fire Fighting Measures =====================
Flash Point:52.0F,11.1C
Lower Limits:6.0%
Upper Limits:36.0%
Extinguishing Media:FOR SMALL FIRES, USE DRY CHEMICAL, CARBON DIOXIDE,
WATER SPRAY OR ALCOHOL-RESISTANT FOAM.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO COOL FIRE-EXPOSED CONTAINERS. WATER
MAY BE INEFFECTIVE.
Unusual Fire/Explosion Hazard:CONTRS CAN BUILD UP PRESS IF EXPOSED TO
HEAT &/FIRE. VAPS CAN TRAVEL TO SOURCE OF IGNIT & FLASH BACK.
DURING FIRE, IRRIT & HIGHLY TOX GASES MAY BE (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP UP WITH A NON-SPARKING TOOL, THEN PLACE
INTO A SUITABLE CONTAINER FOR DISPOSAL. USE WATER SPRAY TO DISPERSE
THE GAS/VAPOR. REMOVE ALL SOURCES OF IGNITION. ABSORB SPILL USING
AN ABSORBENT, NON-CO MBUSTIBLE MATERIAL SUCH AS EARTH, SAND.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION. EMPTY
CONTAINERS RETAIN PRODUCT RESIDUE (LIQUID AND/OR VAPOR), AND CAN BE
DANGEROUS.
Other Precautions:DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL,
GRIND/EXPOSE SUCH CONTRS TO HEAT, SPKS & OPEN FLAMES. DO NOT GET ON
SKIN/IN EYES. DO NOT INGEST/INHALE. KEEP AWAY FROM SOURCES OF
IGNIT. STORE IN CO OL, DRY, WELL-VENTILATED AREA (ING 10)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
29 CFR 1010.134. ALWAYS USE A NIOSH APPROVED RESPIRATOR WHEN
NECESSARY.
Ventilation:USE ADEQUATE GENERAL/LOCAL EXHAUST VENTILATION TO KEEP
AIRBORNE CONCENTRATIONS BELOW PERMISSIBLE EXPOSURE LIMITS.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH & DELUGE
SHOWER . WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN
EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
Supplemental Safety and Health
EXPLO HAZ: GENERATED BY THERMAL DECOMP/COMBUST. FLAMM LIQ. CAN RELEASE
VAPS THAT FORM EXPLO MIXS AT TEMPS ABOVE FLASH POINT. MATLS TO
AVOID: SODIUM HYPOCHLORITE). ACTIVE METALS (SUCH AS POTASSIUM & MA
GNESIUM). SUBSTANCE IS ALSO INCOMPATIBLE W/SPECIFIC CHEMS INCL:
ACETYL BROMIDE, ALKYL ALUMINUM SALTS, BERYLLIUM (ING 2)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:147F,64C
Melt/Freeze Pt:M.P/F.P Text:-144F,-98C
Vapor Pres:29
Vapor Density:1.1
Spec Gravity:0.8 (H*2O=1)
pH:NEUT
Evaporation Rate & Reference:5.2 (ETHER=1)
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID, SLIGHT ALCOHOL-LIKE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDANTS (SUCH AS BARIUM PERCHLORATE, BROMINE, CHLORINE, HYDROGEN
PEROXIDE, LEAD PERCHLORATE, PERCHLORIC ACID, (SUP DAT)
Stability Condition to Avoid:HIGH TEMPERATURES, INCOMPATIBLE MATERIALS,
IGNITION SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
FORMALDEHYDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE, AND LOCAL REGULATIONS. THIS MATERIAL IS BANNED FROM LAND
DISPOSAL ACCORDING TO RCRA.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SUNFIRE ACRYLIC URETHANE, REDUCERS, R7K6204 MEDIUM
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:ACETIC ACID, BUTYL ESTER; (N-BUTYL ACETATE) (CERCLA). VP:10
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 71%
OSHA PEL:150 PPM
ACGIH TLV:150 PPM/200 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHANOL, 2-BUTOXY-, ACETATE; (ETHYLENE GLYCOL MONOBUTYL
ETHER ACETATE). VP:0.8
CAS:112-07-2
RTECS #:KJ8925000
Fraction by Wt: 18%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER. VP:1.8
CAS:108-65-6
RTECS #:AI8925000
Fraction by Wt: 11%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:W/PERM BRAIN & NERV SYS DMG. ANIAMAL STUDIES HAVE
CLEARLY DEMONSTRATED DOSE-RELATED ADVERSE EFTS ON CNS, (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:HEMATOPOIETIC TISS, BLOOD, KIDNEYS & LIVER ASSOC
W/ADMIN OF ETHYLENE GLYCOL MONOBUTYL ETHER ACETATE (EGBA).(ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:(EXTRACTED FROM DHHS (NIOSH) PUB NO. (90-118) .
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH:DO NOT INCIN CLSD CNTNR. DISPOSE OF I/A/W
FEDERAL, STATE, AND LOCAL REGULATIONS REGARDING POLLUTION.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:ONLY TO APPRVD CNTNRS W/COMPLETE & APPROP
LABELING. DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:CHILDREN. INTERNATIONAL MISUSE BY DELIB CONCENTRATING
& INHALING CONTENTS CAN BE HARMFUL/FATAL. USE ONLY (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:W/ADEQ VENT. AVOID BRTHG VAP & SPRAY MIST. AVOID
CONT W/SKIN AND EYES.
RTECS #:9999999ZZ
Ingred Name:VENT:OSHA STANDARDS 1910.94, 1910.107, 1910.108.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPOS MAY BE BY INHAL AND/OR SKIN/EYE
CONT, DEPENDING ON CNDTNS OF USE. ALCOHOLS & ACETATES CAN BE
ABSORBED THRU SKIN. FOLLOW REC FOR PROPER USE, VENT, & PERSONAL
PROT EQUIP TO MINIMIZE EXPOS. ACUTE:I RRIT OF EYES, SKIN & RESP SYS
MAY CAUSENERV SYS DEPRESS. EXTREME OVEREXP MAY RSLT IN UNCON &
POSSIBLY (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:DEATH. SIGNS & SYMPS OF OVEREXP:HDCH,
DIZZ, NAUS, & LOSS OF COORDINATION ARE INDICATIONS OF EXCESS EXPOS
TO VAPS/SPRAY MISTS. REDNESS & ITCHING/BURNING SENSATION MAY
INDICATE EYE/EXCESS SKIN EXPOS. CHRONIC:PRLNGD OVEREXP TO SOLV
INGREDS MAY CAUSE ADVERSE EFTS TO LIVER, URINARY, BLOOD-FORMING,
CARDIO- (SUPDAT)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM &
QUIET. SKIN:WASH AFFECTED AREA THOROUGHLY WITH SOAP & WATER. REMOVE
CONTAMINATED CLOTHING & LAUNDER BEFORE RE-USE. EYES:FLUSH WITH
LARGE AMOU NTS OF WATER FOR @ LEAST 15 MINUTES. GET MEDICAL
ATTENTION. INGEST:GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:72.0F,22.2C
Lower Limits:0.5%
Upper Limits:13.1%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:NIOSH APPRVD SCBA & FULL PROT EQUIP . WATER
SPRAY MAY BE INEFTIVE. IF WATER IS USED, FOG NOZZ ARE PREF. WATER
MAY BE USED TO COOL CLSD CNTNRS TO (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPKS, & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. APPLIC TO HOT SURFS (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPKS, & OPEN
FLAME. VAPS MAY ACCUM READILY & MAY IGNITE EXPLOSIVELY. CONSULT
NFPA CODE. USE APPRVD BONDING & GROUNDING PROC.
Other Precautions:DURING USE & UNTIL ALL VAPS ARE GONE: KEEP AREA
VENTILATED-DO NOT SMOKE-EXTING ALL FLAMES, PILOT LIGHTS, &
HEATERS-TURN OFF STOVES, ELEC TOOLS & APPLIANCES, & ANY OTHER
SOURCES OF IGNIT. KEEP CNTNR CL SD WHEN NOT IN USE. TRANSFER (ING
9)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLIC LIMITS BY VENTILATION, WEAR PROPERLY FITTED
ORGANIC/PARTICULATE RESPIRATOR APPROVED BY NIOSH FOR PROTECTION
AGAINST MATERIALS.
Ventilation:LOC EXHAUST PREF. GEN EXHAUST ACCEPTABLE IF EXPOS TO MATLS
IS MAINTAINED BELOW APPLIC EXPOS LIMITS. REFER TO (ING 12)
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC:PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN EXPOSED
TO EXTREME HEAT. EXPLO HAZ:REQS SPEC PREC. DURING EMER CNDTNS
OVEREXP TO DECOMP PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE IMMED
APPARENT. OBTAIN MED ATTN. EFTS OF OVEREXP:VASCULAR, & REPROD SYS.
RPTS HAVE ASSOC RPTD & PRLNGD OVEREXP TO (ING 5)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>174F,>79C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:0.89
VOC Grams/Liter:7.47
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MAY BE HAZ AS DEFINED UNDER RCRA 40 CFR
261. WASTE MUST BE TESTED FOR IGNITABILITY TO DETERM APPLIC EPA HAZ
WASTE NUMBERS. WASTE FROM PRODS CONTAINING METHYL ETHYL KETONE MAY
ALSO REQ EXTRACTABI LITY TESTING. INCIN IN APPRVD FACILITY.(ING 8)
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:S-W 2216 B/A PART A GRAY EPOXY ADHV. 32.
CAGE:04963
CAGE:04963
============= Composition/Information on Ingredients =============
Ingred Name:AMINE TERMINATED POLYMER- N.J. TRADE SECRET (T.S.) REGISTRY
NO. 04499600-5569P
RTECS #:AT1005687
Minumum % Wt:55.
Maxumum % Wt:70.
Ingred Name:CAOBIN
CAS:1332-58-7
RTECS #:GF1670500
Minumum % Wt:30.
Maxumum % Wt:45.
OSHA PEL:10 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Minumum % Wt:.01
Maxumum % Wt:.1
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT:CHEMICAL RELATED EYE
BURNS(CHEMICAL CORROSIVITY):CLOUDY APPEARANCE OF CORNEA,CHEMICCAL
BURNS,PAIN,TEARING,ULCERS,IMPAIRED VISION/LOSS OF VISION.VAPORS
FROM HEATED MATERIAL MAY CAUSE EYE IR RITATION.DUST CREATED BY
CUTTING,GRINDING,SANDING,/MACHINING MAY CAUSE EYE IRRITATION.SKIN
CONTACT:ALLERGIC SKIN
REACTION:REDNESS,SWELLING,BLISTERING,&ITCHING.MILD SKIN IRRITATION
REDNESS,SWELLING&ITC HING.*
Effects of Overexposure:*INH:IRRTATION(UPPER RESP.SORENESS OF
NOSE&THROAT,COUGHING&SNEEZING.VAPORS OF HEATED MATERIAL:RESP.SYSTEM
IRRTATION.DUST F/CUTTING,GRINDING,SANDING,/MACHININNG:IRRITATION OF
RESP.SYSTEM.INGESTION:IRRT ATION OF GI
TISSUES:PAIN,VOMITING,ABDOMINAL TENDERNESS,NAUSEA,BLOOD IN
VOMITUS&FECES.EXPOSURE IN NORMAL STORAGE&HANDLING HAS NOT BEEN
REPORTED-CAUSE SIGNIFICANT ADVERSE HEALTH EFFECTS.UNDER NORMAL PRO
CESSING CONDITIONS,E.G.GRINDING/HEATING,MAY RELEASE FUMES&VAPORS OF
PROCESS RELEASES MAY PRODUCE IRRITATION/ANY HEALTH EFFECTS LISTED
ABOVE WHEN EMISSIONS ARE PRESENT@ELEVATED CONCENTRATIONS.USE W/APP
ROPRIATE LOCAL EXHAUST VENTILATION.
======================= First Aid Measures =======================
First Aid:EYE CONTACT:IMMEDIATELY FLUSH EYES WITH LARGE AMOUNTS OF
WATER FOR AT LEAST 15 MINUTES. GET IMMEDIATE MEDICAL ATTENTION.
SKIN CONTACT: IMMEDIATELY WASH SKIN WITH SOAP AND LARGE AMOUNTS OF
WATER. REMOVE CONTAMINATED CLOTHING. IF SIGNS/SYMPTOMS OCCUR,
CALL A PHYSICIAN. WASH CONTAMINATED CLOTHING BEFORE REUSE AND
DISPOSE OF CONTAMINATED SHOES. INHALATION: IF SIGNS/SYMPTOMS
OCCUR, REMOVE PE RSON TO FRESH AIR. IF SIGNS/SYMPTOMS CONTINUE,
CALL A PHYSICIAN. INGESTION: IF SWALLOWED DO NOT INDUCE
VOMITING. DRINK TWO GLASSES OF WATER, CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, CO2, FOAM, AND DRY CHEMICAL.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING, INCLUDING
HELMET, SELF CONTAINED, POSITIVE PRESSURE OR PRESSURE DEMAND
BREATHING APPARATUS, BUNKER COAT AND PANTS, BANDS AROUND ARMS,
WAIST AND LEGS, FACE MASK, AND PROT ECTIVE COVERING FOR EXPOSED
AREAS OF THE HEAD.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:REFER TO OTHER SECTIONS OF THIS MSDS FOR
INFORMATION REGARDING PHYSICAL AND HEALTH HAZARDS, RESPIRATORY
PROTECTION, VENTILATION, PERSONAL PROTECTIVE EQUIPMENT. CALL
612-733-1110 OR 612-733-6100 FOR 2 4 HOUR SPILL ASSISTANCE. COVER
WITH ABSORBENT MATERIAL. COLLECT SPILLED MATERIAL. PLACE IN A
U.S. DOT APPROVED CONTAINER AND SEAL .
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HEAT.KEEP OUT OF THE
REACH OF CHILDREN.KEEP CONTAINER TIGHTLY CLOSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID INHALATION OF VAPORS. AVOID INHALATION OF
DUST CREATED BY CUTTING, SANDING OR GRINDING. SELECT ONE OF THE
FOLLOWING NIOSH-APPROVED RESPIRATORS BASED ON AIRBORNE
CONCENTRATION OF CONTAMINANTS A ND IN ACCORDANCE WITH OSHA
REGULATIONS: HALF-MASK DUST RESPIRATOR.
Ventilation:USE IN A WELL-VENTILATED AREA. IF EXHAUST VENTILATION IS
NOT ADEQUATE, USE APPROPRIATE RESPIRATORY PROTECTION.
SHIELDS.
Work Hygienic Practices:DO NOT EAT, DRINK OR SMOKE WHEN USING THIS
PRODUCT. WASH EXPOSED AREAS THOROUGHLY WITH SOAP AND WTER. DO NOT
INGEST.
Supplemental Safety and Health
PROVIDE APPROPRIATE LOCAL EXHAUST FOR GRINDING, CUTTING OR SANDING
CURED MATERIAL. CURING OVENS MUST BE EXHAUSTTED TO OUTDOORS OR TO
A SUITABLE EMISSION CONTROL DEVICE.
================== Physical/Chemical Properties ==================
Spec Gravity:1.26 (WATER= 1)
Viscosity:40000-80000 CPS
Appearance and Odor:GRAY PASTE/ PUNGENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HEAT IS GENERATED DURING CURE.DO NOT CURE A MASS LARGER THAN 50-
GRAMS IN A CONFINED SPACE TO PREVENT A PREMATURE REACTION
(EXOTHERMIC) WITH PRODUCTION OF INTENSE HEAT AND SMOKE.
Hazardous Decomposition Products:CO, CO2, OXIDES OF NITROGEN, AMINE
COMPOUNDS, TOXIC VAPORS, GASES OR PARTICULATES.
==================== Disposal Considerations ====================
Waste Disposal Methods:CURE PRODUCT ACCORDING TO PRODUCT INSTRUCTIONS.
INCINERATE UNCURED WASTE IN AN INDUSTRIAL OR COMMERCIAL
INCINERATOR. DISPOSE OF COMPLETELY CURED (OR POLYMERIZED) MATERIAL
IN A SANITARY LANDFILL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TT-E-489 ALKYD ENAMEL 14187
CAGE:HO534
CAGE:HO534
CAGE:33244
============= Composition/Information on Ingredients =============
Ingred Name:CHROMIUM (SARA III)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 1.09%
Other REC Limits:0.05 MG/M3
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: <1%
Other REC Limits:N/K
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 10%
Other REC Limits:N/K
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9293
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: <1%
Other REC Limits:N/K /ORNL
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL ALCOHOL (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: <1%
Other REC Limits:N/K
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9192
Ingred Name:LEAD COMPOUNDS
CAS:70084-67-2
Fraction by Wt: <1%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:EXPLAN OF CARCIN:CR & CERTAIN CR CMPDS:KNOWN HUMAN
CARCINOGEN (NTP,1985).
RTECS #:9999999ZZ
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUND:3.95 LB/GAL (473 G/LT)
RTECS #:9999999VO
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:PROLONGED & REPEATED OCCUPATIONAL
OVEREXPOS TO SOLV MAY LEAD TO PERMANENT BRAIN & NERV SYS
DAMAGE.REPEATED EXPOS MAY CAUSE DELAYED EFFECTS ON
BLOOD,GI,NERVOUS,REPRO SYSTEM.INGEST MAY RESULT IN TOXIC L EVELS OF
PB IN BODY.THIS PRODUCT CONTAINS ONE OR MORE CHEM KNOWN TO CAUSE
CANCER,BIRTH DEFECTS,& OTHER REPRO HARM.
Explanation of Carcinogenicity:CR(VI) CMPDS:SUFF EVID FOR CARC IN
HUM/ANIM;INORG PB CMPDS:INAD EVID FOR CARC INHUM/SUFFICIENT EVID IN
ANIM (SEE SUP)
Effects of Overexposure:EYES:IRRIT,WATERING,BLURRED VISION.SKIN:SEV
IRRIT,BURNING,DRYING,CRACKING,DEFAT.MAY BE
ABSORBED.INGEST:DIZZ,NAUS,GI IRRIT,VOMIT.INHAL:ANESTH.IRRIT RESP
TRACT,DIZZ,NAUS,HDACH,VOMIT,UNCON,COMA,ASPHIX.CA UTION:CHRONIC
OVEREXPOS MAY CAUSE METALLIC TASTE IN MOUTH,APPETITE
LOSS,CONSTIP,ABDOMINAL CRAMPS,SLEEPLESSNESS,WEAKNESS.
Medical Cond Aggravated by Exposure:PRE-EXISTING
HEART,LIVER,KIDNEY,LUNG,SKIN DISORDERS.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/ LRG AMOUNTS OF WATER FOR AT LEAST 15 MIN W/
LIDS OPEN.CONSULT MD IMMED.SKIN:WASH WITH SOAP AND WATER;REMOVE
CONTAM CLOTHING.INGESTION:DO NOT INDUCE VOMITING.DRINK ONE OR TWO
GLASSES OF W ATER TO DILUTE.SEEK MEDICAL ASSISTANCE
IMMEDIATELY.INHALATION:REMOVE FROM EXPOSURE,RESTORE
BREATHING,CONSULT PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:106F,41.11C
Upper Limits:1.0%
Extinguishing Media:FOAM,CO*2,DRY CHEMICAL,WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROT EQUIP
.FIGHT AS VOLAT LIQ FIRE.USE H*2O TO COOL FIRE-EXPOS CONTRS.AVOID
SPREADING FIRE W/ COOLING H*2O. (SEE SUP)
Unusual Fire/Explosion Hazard:CLOSED CONT MAY EXPLODE IN EXTREME
HEAT.VAPS MAY MOVE BY VENT OR TRAVEL ON GROUND TO DISTANT IGNIT
SOURCES.EMPTY CONTRS MAY EXPLODE DUE TO RESIDUES. (SEE SUPP)
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA.REMOVE ALL SOURCES OF
IGNITION.CONTAIN AND REMOVE WITH INERT ABSORBANT AND NON-SPARKING
TOOLS.WEAR PROTECTIVE EQUIPMENT DURING CLEANUP.CONTAIN LIQUID TO
PREVENT CONTAMINATION OF SOIL AN D GROUND WATER.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CLOSURE TIGHT AND CONTR IN
UPRIGHT POSITION.STORE AWAY FROM HEAT & SOURCES OF IGNIT.CONTRS
MUST BE GROUNDED &/OR BONDED DURING LIQUID TRANSFER.
Other Precautions:AVOID PROLONGED BREATHING OF VAP,SKIN OR EYE
CONTACT.AFTER CONTACT THOROUGHLY WASH W/ WATER.DO NOT TAKE
INTERNALLY.EMPTIED CONTAINERS MAY STILL CONTAIN HAZARDOUS MATERIALS
SO THIS MSDS MUST BE OBSERVE D WHEN HANDLING THEM.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Other Protective Equipment:EYE WASH AND SAFETY SHOWERS IN WORK AREA ARE
RECOMMENDED.
Work Hygienic Practices:WASH WITH SOAP AND WATER,REMOVE CONTAMINATED
CLOTHING.SHOWER DAILY AND CHANGE CLOTHES INCLUDING UNDERGARMENTS.
Supplemental Safety and Health
FIRE FIGHT PROC:FOG NOZZLES ARE REC.EXPLO HAZ:OBSERVE MSDS FOR EMPTIED
CONTR HANDLING.METAL CONTRS MUST BE GROUNDED &/OR BONDED DURING LIQ
TRANSFER.HAZ DECOMP PROD:CO*2,CO,OTHER OXIDES,TOX FUMES,SMOKE
.EXPLAN OF CARCIN:(IARC,1987).ACGIH (WATER INSOL CR(VI) CMPDS)
A1=CONFIRMED HUMAN CARCINOGEN (1989). (SEE INGRED #7)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:314F,156.7C
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/K
Vapor Density:>1 (AIR=1)
Spec Gravity:0.9 (WATER=1)
Evaporation Rate & Reference:>1 (ETHER=1)
Solubility in Water:N/K
Appearance and Odor:VISCOUS LIQUID WITH MINERAL SPIRITS ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZING AGENTS,ACIDS AND BASES.
Stability Condition to Avoid:AVOID HEAT,ELECTRICAL
EQUIPMENT,SPARKS,OPEN FLAME.
Hazardous Decomposition Products:CARBON DIOXIDE,CARBON MONOXIDE,OTHER
OXIDES,TOXIC FUMES AND SMOKE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:16-2002 RESIN-HYDROCARBON
CAGE:59581
CAGE:59581
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM DIOXIDE, TIO2
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 6-11%
Other REC Limits:375 MG/CUM
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:V M & P NAPHTHA, LIGROINE, MINERAL SPIRITS
CAS:8032-32-4
RTECS #:OI6180000
Other REC Limits:STEL 400 PPM
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 2-6%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
CAS:75-28-5
RTECS #:TZ4300000
Other REC Limits:1000 PPM
OSHA PEL:1800 MG/CUM
ACGIH TLV:1000 PPM
Ingred Name:METHANOL (METHYL ALCOHOL), COLUMBIAN SPIRITS
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 6-8%
Other REC Limits:200 PPM
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CHEMICALLY NEUTRALIZED MIDDLE DISTILLATE (PETROLEUM)
93/1
CAS:64742-30-9
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY SYSTEM
IRRITATION. EYES: IRRITATION. INGESTION: ACCIDENTAL INGESTION IS
UNLIKELY FROM AN AEROSOL CAN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION:
IRRITATION/HEADACHE/DIZZINESS/NAUSEA/UNCONSCIOUS/ASPHYXIA. SKIN:
DEFATTING LEADING TO IRRITATION/DERMATITIS. METHYL ALCOHOL: CNS
(OPTIC NERVE) EFFECTS/FATAL/BLINDNESS/POISONOUS ABSORPTION/ LIVER
DAMAGE/DEATH. VM&P: SKIN IRRITATION/CNS DEPRESSION. TOLUENE:
CARDIAC EFFECTS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING STOPS, BEGIN
ARTIFICIAL RESPIRATION. EYES: IMMEDIATELY FLUSH W/PLENTY OF WATER
FOR AT LEAST 15 MINS. SKIN: WASH W/SOAP & WATER. INGESTION: OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:-10F
Lower Limits:0.7%
Upper Limits:9.5%
Extinguishing Media:CO2, DRY CHEMICAL, OR FOAM
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. WATER MAY BE
USED TO COOL CONTAINERS TO PREVENT BURSTING. IF WATER IS USED, FOG
Unusual Fire/Explosion Hazard:EXPOSURE TO HEAT OR PROLONG EXPOSURE TO
SUN MAY CAUSE BURSTING.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
BREATHING VAPORS. VENTILATE AREA. WIPE UP W/INERT MATERIALS & PLACE
IN APPROPRIATE CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE >120F. USE ONLY AS
DIRECTED. AVOID CONTINUOUS BREATHING OF VAPORS & SPRAY MIST.
Other Precautions:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING
VAPORS & INHALING CONTENTS CAN BE HARMFUL OR FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR SELF-CONTAINED BREATHING APPARATUS FOR
CONCENTRATIONS ABOVE TLV LIMITS.
Ventilation:USE W/ADEQUATE VENTILATION, SUFFICIENT TO PREVENT
INHALATION OF SOLVENT VAPORS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Pres:40 PSIA
Vapor Density:>1
Evaporation Rate & Reference:FASTER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:PAINT SOLVENT ODOR.
Percent Volatiles by Volume: 85%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:TEMPS >120F, SPARKS, PILOT LIGHT, OPEN
FLAME, SUN, OR OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:HAZARDOUS FUMES SUCH AS CO, CO2,
PHOSGENE, HYDROGEN CHLORIDE, & CHLORINATED ACIDS, ALDEHYDES, &
KETONES
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T INCINERATE AEROSOL, DISPOSE OF IN
ACCORDANCE W/LOCAL, STATE, & FEDERAL REGULATIONS. DON'T PLACE
AEROSOL CANS IN HOME COMPACTOR. DON'T PUNCTURE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:INDICATOR SILICA GEL
CAGE:JOSEP
CAGE:JOSEP
============= Composition/Information on Ingredients =============
Ingred Name:SILICA GEL
Ingred Name:COBALT CHLORIDE, AMORPHOUS HYDRATED
Fraction by Wt: 0.5%
===================== Hazards Identification =====================
Effects of Overexposure:COBALT CHLORIDE IS KNOWN TO CAUSE ASTHMATIC
EFFECTS AFTER PROLONGED INHALATION.
======================= First Aid Measures =======================
First Aid:IN EVENT OF AN ACCIDENT IN WHICH A PERSON IS COVERED IN THE
MATERIAL, WASH EXPOSED PARTS W/PLENTY OF WATER & CHANGE OVERALLS.
IN EVENT OF MATERIAL ENTERING THE EYE WASH W/PLENTY OF WATER & SEE
MED ADV ICE, IN CASE OF INGESTION SEND PERSON TO HOSP.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Extinguishing Media:NOT FLAMMABLE _
Fire Fighting Procedures:NOT FLAMMABLE
Unusual Fire/Explosion Hazard:NOT FLAMMABLE
================== Accidental Release Measures ==================
Spill Release Procedures:THE SPILT POWDER IS BRUSHED UP AND PLACED IN
CLOSED BAGS. THE MATERIAL MAY BE WETTED/WATER TO MINIMISE DUSTING.
SPILLAGE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN DRY PLACE TO PRESERVE
DESICCANT PROPERTIES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DUST MASK
Ventilation:LOCAL EXHAUST/MECHANICAL: IF AVAILABLE.
Other Protective Equipment:NONE
Supplemental Safety and Health
MSDS UNDATED
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:3,600F
Spec Gravity:2.2
Solubility in Water:NIL
Appearance and Odor:BLUE GRANULES WHICH TURN PINK WHEN SAT W/WATER.
Percent Volatiles by Volume:6%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STORE IN DRY PLACE TO PRESERVE DESICCANT PROPERTIES.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN CLOSED BAGS AT APPROVED TIP SITES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:GREEN 383 POLYEURETHANE COATING #07110GWU
Kit Part:Y
Preparer's Name:JANE FREEMAN
CAGE:09225
CAGE:09225
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 30-40%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICA
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:TALC (CONTAINING ASBESTOS)
CAS:14807-96-6
RTECS #:MW2700000
Fraction by Wt: 1-5.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2.0MG/M3 FIBERS/CC
ACGIH TLV:2.0 MG/M3 FIBER/CC
Ingred Name:1-METHYLPYRROLIDONE
CAS:872-50-4
RTECS #:UY5790000
Fraction by Wt: 4.385%
Other REC Limits:200 PPM MFR
Ingred Name:SILICA
CAS:7631-86-9
Fraction by Wt: 1-5.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:CHROMIUM (III) OXIDE (SARE 313)
CAS:1308-38-9
RTECS #:GB6475000
Fraction by Wt: 14.555%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.5 MG/M3
ACGIH TLV:0.5 MG/M3
Ingred Name:COBALT (SARA 313)
CAS:7440-48-4
RTECS #:GF8750000
Fraction by Wt: 0.96%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.05 MG/M3
ACGIH TLV:0.05 MG/M3
Ingred Name:ZINC (SARA 313) (CERCLA)
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: 1.571%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TRIVALENT CHROME (SARA 313)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 3.579%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.5 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:CHRONIC: INHAL: HEADACHE, NAUSEA,
IRRIT TO RESPIRATORY PASSAGES. SKIN: IRRITATION, DEFATTING,
DERMATITIS. EYE: IRRITATION., OTHER: BRAIN/NS/LIVER/KIDNEY DAMAGE,
DELAYED RESPIRATORY SYSTEM EFFECTS, LUN G INJURY.
Explanation of Carcinogenicity:IARC SILICA IS LISTED AS A PROBABLE
HUMAN CARCINOGEN, COBALT IS LISTED AS POSSIBLY CARCINOGENIC.
Medical Cond Aggravated by Exposure:ASTHMA AND OTHER RESPIRATORY
AILMENTS; CHEMICAL SENSITIZATION.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM &
QUIET. NOTIFY A PHYSICIAN. EYES: FLUSH IMMEDIATELY WITH LARGE
AMOUNTS OF RUNNING WATER FOR AT LEAST 15 MINUTES. LIFT LIDS. TAKE
TO PHYSICIAN FOR MEDICAL TREATMENT. SKIN: WASH WITHSOAP & WATER.
REMOVE CONTAM CLOTHES, WASH BEFORE REUSE, CALL DR. INGEST: CALL
DR/POISON CONTROL CENTER IMMED.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>201F,>94C
Autoignition Temp:Autoignition Temp Text:NA
Lower Limits:1.0
Upper Limits:11.2
Extinguishing Media:ALCOHOL FOAM, WATER FOG, CARBON DIOXIDE
Fire Fighting Procedures:WEAR PROTECT EQUIP INCLUDING SCBA. WATER MAY
BE INEFFECTIVE, USE WATER (FOG NOZZLES PREFERRED) COOL CLOSED CNTNR
TO PREVENT PRESSURE BLDUP,AUTOIGNITN,EXPLOSION.
Unusual Fire/Explosion Hazard:KEEP CONTAINER TIGHTLY CLOSED. NO IGNITS
CONTAINER MAY EXPLODE W.HEAT DONT WELD/TORCH ON/NEAR CONTAINER.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE
AREA. USE APPROPRIATE PROTECTIVE EQUIPMENT. AVIOD BREATHING
VAPORS/SKIN CONTACT. PREVENT ENTRY TO DRAINS/SEWERS/WATERWAYS.
NOTIFY AUTHORITIES. CONTAIN & REMOV E WITH INERT ABSORBENT AND
NONSPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:DONT STORE @>120F. LARGE AMTS IN
BUILDINGS DESIGNED (OSHA 1910.106). NO IGNITS. KEEP
CLOSED/UPRIGHT/TIGHT WHEN NOT IN USE. EMPTY CNTNR HAZARDOUS.
Other Precautions:SOAK SOILED RAGS/WASTES IN H2O FILLED CLOSED CNTNR.
USE W/ADEQUATE VENT, AVOID VAPOR BREATHING/SKIN CONTACT,
GROUND/BOND WHEN TRANSFERRING, AVOID FREEFALL OF LIQ >FEW INCHES,
USE SPARKPROOF TOOLS/EXPL OSION PROOF EQUIPMENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:OUTDOOR/SANDING/GRINDING: NIOSH MECHANICAL
FILTER RESPRTR. CONFINED AREA: NIOSH AIR SUPPLIED RESPIRATOR/HOOD.
AIR MONITORING MAY BE REQUIRED.
Ventilation:GENERAL DILUTION/LOCAL EXHAUST TO KEEP BELOW PEL/TLV.
Other Protective Equipment:APPROPRIATE TO PREVENT PROLONGED SKIN
CONTACT.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR SMOKING. SMOKE IN
DESIGNATED SMOKING AREAS ONLY.
Supplemental Safety and Health
NMORE INFORMATION ON FILE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:209 TO 400F
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Vapor Pres:20 @ 68F
Vapor Density:> AIR
Spec Gravity:1.49
pH:8.3
VOC Grams/Liter:1.29
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Solubility in Water:APPRECIABLE
Appearance and Odor:OPAQUE LIQUID, MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO DECOMPOSITION AS IN WELDING. MAY CONTAIN CARBON MONOXIDE
& CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:RECYCLE OR INCINERATE IN ACCORDANCE WITH LOCAL,
STATE, & FEDERAL REGULATIONS.
======================= Other Information =======================
======================================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DEVRAN 229 NEUTRAL TINT BASE, 229B9502
CAGE:1HK86
CAGE:1HK86
============= Composition/Information on Ingredients =============
Ingred Name:ING 11: MISUSE BY DELIBERATELY CONCENTRATING AND INHALING
THE CONTENTS MAY BE HARMFUL OR FATAL.
RTECS #:9999999ZZ
Ingred Name:ING 12:WHEN NOT IN USE. DO NOT TRANSFER CONTENTS TO
BOTTLES/OTHER UNLABELLED CNTNRS. DO NOT REUSE EMPTY CNTNRS. (ING
14)
RTECS #:9999999ZZ
Ingred Name:HNDLG/STOR PREC: HEATERS, FANS/OTHER NON-EXPLOSION PROOF
ELECTRICAL EQUIPMENT, DURING USE & UNTIL ALL VAPORS ARE GONE.
RTECS #:9999999ZZ
Ingred Name:ING 14:OF BOTH COMPONENTS. OBSERVE ALL APPLICABLE
PRECAUTIONS. WARNING! THIS PROD MAY CONTAIN A CHEMICAL KNOWN (ING
16)
RTECS #:9999999ZZ
Ingred Name:ING 15: DO NOT REUSE EMPTY CONTRS. IF THIS MATL IS PART OF
A 2 COMPONENT PROD, THEN MIX OF BASE & CONVERTER (ING 17)
RTECS #:9999999ZZ
Ingred Name:RESP PROT:USED IN RESTRICTED VENT AREAS, WEAR NIOSH/MSHA
APPRVD CHEMICAL/MECHANICAL FILTER DESIGNED TO REMOVE A (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17: CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER, BIRTH DEFECTS/OTHER REPRODUCTIVE HARM (CAL PROP 65).
RTECS #:9999999ZZ
Ingred Name:ING 18:RESPIRATORS OR USE HOODS. USE NIOSH/MSHA APPROVED
RESPIRATOR WHEN FLAME CUTTING, WELDING, BRAZING AND (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19: COMBINATION OF PARTICULATES & VAP. WHEN USED IN
CONFINED AREAS, WEAR NIOSH/MSHA APPRVD AIR SUPP RESP/ (ING 21)
RTECS #:9999999ZZ
Ingred Name:VENT:HEALTH STDS IN THE MIXING, APPLICATN & CURING AREAS &
TO REMOVE SANDING DUSTS OF DRIED COATINGS & DECOMP (ING 22)
RTECS #:9999999ZZ
Ingred Name:VENT: STDS IN MIXING, APPLICATION & CURING AREAS & TO
REMOVE SANDING DUSTS OF DRIED COATINGS & DECOMP PRODS (ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22:BUILD-UP BY REMOVING HEAVY SOLVENT VAPORS FROM LOWER
LEVELS OF THE WORK AREA. ELIMINATE ALL IGNITION SOURCES.
RTECS #:9999999ZZ
Ingred Name:ING 23: REMOVING HEAVY SOLVENT VAPORS FROM LOWER LEVELS OF
THE WORK AREA. ELIMINATE ALL IGNITION SOURCES.
RTECS #:9999999ZZ
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (HIGH FLASH
AROMATIC NAPHTHA). VP: 10. LD50 (ORAL, RAT): >5 G/KG.
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 20%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BISPHENOL A-EPICHLOROHYDRIN COPOLYMER; (EPOXY RESIN)
CAS:25068-38-6
RTECS #:SL6475000
Fraction by Wt: 10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLYAMIDE. VP: <1. LD50 (ORAL, RAT): 8G/KG
CAS:68082-29-1
Fraction by Wt: 30%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACETIC ACID, BUTYL ESTER; (N-BUTYL ACETATE) (CERCLA) VP: 13
LD50 (ORAL RAT): 14 G/KG
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 15%
OSHA PEL:150 PPM
ACGIH TLV:150 PPM/200STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VOLATILE ORGANIC CONTENT: 516.76 (GRAMS/LITER)
RTECS #:9999999VO
Ingred Name:ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER; (PROPYLENE
GLYCOL MONOMETHYLETHER ACETATE) VP: 3.7 LD50 (ORAL RAT): 8.5 G/KG
CAS:108-65-6
RTECS #:AI8925000
Fraction by Wt: 15%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ING 6:PRODUCTS MAY CAUSE A HEALTH HAZARD. SYMPTOMS MAY NOT
BE IMMEDIATELY APPARENT. OBTAIN MEDICAL ATTENTION.
RTECS #:9999999ZZ
Ingred Name:VOLATILE ORGANIC CONTENT: 551.09 G/L
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ING 8:WHICH CAN BE FATAL. NOTICE:INTENTIONAL MISUSE BY
DELIB CONCENTRATING & INHALING THE CONTENTS MAY BE HARMFUL/FATAL.
RTECS #:9999999ZZ
Ingred Name:ING 9: HEALTH HAZARD. SYMPTOMS MAY NOT BE IMMEDIATELY
APPARENT. OBTAIN MEDICAL ATTENTION.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:DOORS. PVNT BUILD-UP OF VAPS BY MAINTAINING
CONTINUOUS FLOW OF FRESH AIR. DO NOT STORE ABOVE 120 (ING 12)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: IRRIT OF RESP TRACT;
HDCH, NAUS, DIZZ, WEAK & FATG. EXTREME EXPOS CAN RSLT IN UNCON &
EVEN RESP ARREST. SKIN/EYE: IRRIT. MAY BE HARMFUL IF ABSORBED THRU
SKIN. INGEST: CAN CAUSE STOM &/IN TESTINAL IRRIT, NAUS, VOMIT &
DIARR. CHRONIC: REPORTS HAVE ASSOC RPTD & PRLNG OCCUP OVEREXP TO
SOLV (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: W/PERM BRAIN & NERV SYS DMG.
PRLNG/RPTD BRTHG OF SPRAY MIST &/SANDING DUST OVER PERIOD OF YRS
MAY CAUSE DUST DISEASE OF LUNGS.
Medical Cond Aggravated by Exposure:NONE, WHEN USED IN ACCORDANCE WITH
SAFE HANDLING AND USE INFORMATION.
======================= First Aid Measures =======================
First Aid:INHAL: IF DFCLT BRTHG, OBTAIN FRESH AIR. IF CONTINUED DFCLT
BRTHG EXPERIENCED, SUMMON MED ASSIST IMMED. IF BRTHG CEASES,
RESTORE USING APPRVD CPR TECHNIQUES & SUMMON MED HELP IMMED. EYE:
FLUSH IMMED W /LGE AMTS OF WATER FOR AT LEAST 15 MIN.GET MED
ASSIST. SKIN: WASH AFFECTED AREAS W/SOAP & WATER. REMOVE SOILED
CLTHG. GET MED ASSIST IF IRRIT PERSISTS. INGEST: CONSULT MD IMMED.
(ING 11)
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:80.0F,26.7C
Lower Limits:1%
Extinguishing Media:USE CARBON DIOXIDE, DRY CHEMICAL, FOAM, OR OTHER
NFPA APPROVED METHOD FOR TREATING A CLASS B FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. SUMMON PROFESSIONAL FIREFIGHTERS. WATER SPRAY MAY BE INEFFECTIVE.
IF WATER IS USED, FOG NOZZ ARE (SUP DAT)
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPARKS & FLAME. VAPS MAY CAUSE FLASH FIRE. VAPS
MAY IGNITE EXPLO. VAPS MAY SPREAD LONG DIST & (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT (FLAMES, HOT SURF,
& ELEC, STATIC/FRICTIONAL SPARKS). PVNT BRTHG OF VAPS. VENT AREA.
BEFORE ATTEMPTING CLEAN-UP, REFER TO HAZ CAUTION INFO IN OTHER
SECTION OF THIS MSDS. CO NTAIN SPILLED MATL & REMOVE W/INERT (ING
13)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT IN EYES/ON SKIN. KEEP AWAY FROM
HEAT, SPARKS & FLAMES. DO NOT SMOKE. EXTING ALL PILOT LIGHTS & TURN
OFF ALL SOURCES OF IGNIT INCL (ING 14)
Other Precautions:VAPS MAY IGNITE EXPLO. VAPS MAY SPREAD LONG DIST &
BEYOND CLSD DOORS. PVNT BUILD-UP OF VAPS BY MAINTAINING CONTINUOUS
FLOW OF FRESH AIR. DO NOT STORE > 120F/NEAR FIRE/OPEN FLAME. STORE
LGE QTYS IN BLD GS TO COMPLY W/OSHA 1910.106. (ING 15)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DO NOT BREATHE VAPS, SPRAY MIST/SANDING DUST.
WHEN SPRAY APPLIED IN OUTDOOR/OPEN AREAS, & DURING SANDING/GRINDING
OPERATIONS, USE NIOSH/MSHA APPRVD MECH FILTER RESP TO REMOVE SOLID
AIRBORNE PARTICLESOF OVERSPRAY & SANDING DUST. (ING 19)
Ventilation:PROVIDE GEN DILUTION/LOC EXHAUST VENT IN VOL & PATTERN TO
KEEP AIR CONTAM CONC BELOW CURRENT APPLIC SFTY & HLTH (ING 22)
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
SOLV IMPERMEABLE CLTHG & BOOTS TO PVNT SKIN CONT ARE RECOMMENDED.
Work Hygienic Practices:REMOVE AND WASH SOILED CLOTHING BEFORE REUSE.
WASH HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health
FIRE FIGHT PROC: PREFERABLE. IF EXPOSED TO EXTREME HEAT, WATER SHOULD
BE USED TO COOL CLSD CONTRS & PVNT PRESS BUILD-UP/POSS AUTOIGNIT.
EXPLO HAZ: BEYOND CLSD DOORS. DUE TO PRESS BUILD-UP, CLSD CONTRS
EXPOSED TO EXTREME HEAT MAY EXPLODE. NEVER USE WELDING/CUTTING
TORCH ON/NEAR CONTR (EVEN EMPTY) AS PROD/ITS (ING 9)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>244F,>118C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER
Percent Volatiles by Volume:63.14
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY CAUSE TOXIC FUMES WHEN HEATED TO
DECOMPOSITION. FUMES MAY CONTAIN CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS. INCINERATE ONLY IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SAFEWAY KA
CAGE:0U3B1
CAGE:0VTU2
CAGE:0K5L3
CAGE:0U3B1
CAGE:67423
CAGE:67243
============= Composition/Information on Ingredients =============
Ingred Name:ACETIC ACID,POTASSIUM SALT/POTASSIUM ACETATE
CAS:127-08-2
RTECS #:AJ3325000
Fraction by Wt: 50.6%
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 49.4%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE- EYES:SLIGHT IRRITATION. MAY
CAUSE PAIN, TEARS, SWELLING, REDNESS & BLURRED VISION. SKIN:NOT
EXPECTED TO CAUSE PROLONGED/SIGNIFICANT IRRITATION. INHALATION:NO
INHALATION HAZARD. INGESTION:MAY CA USE IRRITATION OF DIGESTIVE
TRACT WHICHMAY RESULT IN NAUSEA, VOMITING & DIARRHEA. CHRONIC- NONE
KNOWN.
Effects of Overexposure:SLIGHT EYE IRRITATION. MAY CAUSE PAIN, TEARS,
SWELLING, REDNESS & BLURRED VISION. NOT EXPECTED TO CAUSE
PROLONGED/SIGNIFICANT SKIN IRRITATION. NO INHALATION HAZARD.
INGESTION MAY CAUSE IRRITATION OF D IGESTIVE TRACT WHICH MAY RESULT
IN NAUSEA, VOMITING & DIARRHEA.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. SKIN:WASH WITH
SOAP & WATER. REMOVE CONTAMINATED CLOTHING. EYE:FLUSH WITH WATER
FOR 15 MINUTES, HOLDING EYELIDS OPEN. INHALED:REMOVE TO FRESH AIR,
IF NECESSA RY. ORAL:IF CONSCIOUS, DRINK MILK/WATER& CALL PHYSICIAN.
DO NOT INDUCE VOMITING UNLESS DIRECTED TO DO SO BY MEDICAL
PERSONNEL.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:NON-FLAMMABLE. AFTER WATER EVAPORATES, REMAINING
MATERIAL WILL BURN. USE FOAMS (STANDARD/ALCOHOL), CO2 OR DRY
CHEMICALS.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND
NIOSH-APPROVED SELF CONTAINED BREATHING APPARATUS. COOL FIRE
EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:DEHYDRATED MATERIAL WILL BURN. NORMAL
COMBUSTION FORMS CARBON DIOXIDE.
================== Accidental Release Measures ==================
Spill Release Procedures:THIS MATERIAL IS NOT EXPECTED TO PRESENT ANY
ENVIRONMENTAL PROBLEM.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE- STORE AWAY FROM STRONG
OXIDIZING AGENTS AND STRONG ACIDS.
Other Precautions:WASH THOROUGHLY AFTER HANDLING. AVOID CONTACT WITH
EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:NO SPECIAL VENTILATION IS NECESSARY.
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER, IMPERVIOUS
CLOTHING IF NEEDED
Work Hygienic Practices:PRACTICE GOOD HYGIENIC PROCEDURE. WASH
THOROUGHLY BEFORE EATING OR DRINKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text: 241F,116C
Melt/Freeze Pt:M.P/F.P Text:<-94F,<-70C
Spec Gravity:1.275
pH:9-10.5
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR COLORLESS TO LIGHT STRAW LIQUID - NEARLY
SCENTLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY REACT WITH STRONG ACIDS OR STRONG OXIDIZING AGENTS SUCH AS
CHLORATES, NITRATES, PEROXIDES, ETC.
Stability Condition to Avoid:EXCESSIVE HEAT (ABOVE 100C)
Hazardous Decomposition Products:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN CONFORMITY WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ENTERORISE 1000,LUBRICATING OIL,WATCH.
Preparer's Name:V.C.W.
CAGE:2S598
CAGE:2S598
============= Composition/Information on Ingredients =============
Ingred Name:"NOT HAZARDOUS"
Fraction by Wt: 100%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC-EYES/SKIN:NOT
ESTABLISHED.INHALATION:LOW HAZARD.INGESTION:EXPECTED LOW.
Effects of Overexposure:SEE HEALTH HAZARDS SECTION.
Medical Cond Aggravated by Exposure:NOT DETERMINED
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IF NEEDED.INHALATION/INGESTION:NONE
SHOULD BE NEEDED.EYES:IMMEDIATELY FLUSH WITH WATER FOR 15
MINUTES.SKIN:FLUSH WITH WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:392F,200C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH INERT ABSORBENT MATERIAL SUCH AS
VERMICULITE AND PLACE IN IMPERVIOUS CONTAINER.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,WELL VENTILATED AREA
AWAY FROM OXIDIZING AGENTS.
Other Precautions:DO NOT BREATHE MIST.AVOID PROLONGED OR REPEATED
BREATHING OF VAPOR.AVOID CONTACT WITH EYES AND SKIN. WASH HANDS
BEFORE EATING OR DRINKING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:VENTILATE AS NEEDED TO COMPLY WITH EXPOSURE LIMIT.
Other Protective Equipment:EYE WASH STATION.
Work Hygienic Practices:WASH HANDS AFTER HANDLING PRODUCT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:752F,400C
Vapor Pres:1.5
Vapor Density:1.06
Spec Gravity:1.0
Evaporation Rate & Reference:NEGLIGIBLE
Solubility in Water:NONE
Appearance and Odor:COLORLESS TO YELLOW LIQUID-SLIGHT WOOD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:DIRECT FLAME
Hazardous Decomposition Products:CARBON DIOXIDE AND WATER
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE BY INCINERATION OR CONTRACT WITH
LICENSED CHEMICAL WASTE DISPOSAL AGENCY.DISCHARGE OR TREATMENT MAY
BE SUBJECT TO FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ZINC OXIDE GRADE CR-40
CAGE:GHCHM
CAGE:GHCHM
============= Composition/Information on Ingredients =============
Ingred Name:ZINC OXIDE
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: +99.8%
OSHA PEL:15MG/M3 TDUST/5 FUME
ACGIH TLV:10MG/M3 TDUST; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:ZINC OXIDE DUST WHICH IS
NOT FRESHLY FORMED IS VIRTUALLY INNOCUOUS. INHAL FRESHLY FORMED
ZINC OXIDE FUMES MAY CAUSE FLU LIKE ILLNESS CALLED METAL FUME
FEVER. SYMP:SWEAT/ SHIVER/HDCH/FEVER/ CHILLS/THIRST, MUSCLE ACHES,
NAUS, VOMIT, WEAK, & TIREDNESS. SYMP OCCUR 4 TO 12 HR AFTER EXPOS
&(SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:USUALLY LAST UP TO 24 HR. SKIN: SHORT
TERM EXPOS DOES NOT CAUSE SYMP OF SKIN IRRIT. EYE:SHORT TERM EXPOS
MAY CAUSE MILD IRRIT. CHRONIC:THERE ARE NO CUMULATIVE EFTS AS RSLTH
OF LONG TERM EXPOSTO ZINC OXIDE DUST/FUMES. SKIN:OCCUP DERM(OXIDE
POX) CAN OCCUR IN CASES WHERE ZINC OXIDE DUST COMBINES
W/DEBRIS(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: IF EXPOSED TO AMOUNTS OF ZINC OXIDE FUME ABOVE TLV
LIMITS, MOVE VICTIM TO FRESH AIR. TREAT ACCORDING TO THE SYMPTOMS.
SKIN: WASH CONTACTED AREA THOROUGHLY WITH NON-ABRASIVE SOAP AND
WATER. IF S KIN IRRITATION OCCURS AND PERSISTS, SEEK MED ADVICE.
EYE: IF IRRITATION OCCURS, FLUSH CONTAMD EYE WITH LUKEWARM GENTLY
FLOWING WATER FOR AT LEAST 20 MIN. IF IRRITATION PERSISTS, OBTAIN
MED ATTN IMMED.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:SHOVEL SPILLED PRODUCT INTO CLEAN, DRY
LABELLED CONTAINERS AND COVER. SWEEP AND/OR FLUSH AREA CLEAN WITH
WATER. PROVIDE ADEQUATE VENTILATION TO PREVENT DUST ACCUMULATION
DURING CLEANUP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN ZINC OXIDE AWAY FROM ITS
INCOMP MATL. STORE IN SUITABLE/LBLD CONTR IN DRY PLACE. KEEP CONTR
TIGHTLY CLSD WHEN NOT IN USE & WHEN (SUPP DATA)
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED DUST MASK OR MECHANICAL
FILTER RESPIRATOR.
Ventilation:PROVIDE LOCAL EXHAUST &/OR GENERAL MECHANICAL VENTILATION
TO ADEQUATELY PREVENT BUILDUP OF DUST OR FUMES ABOVE LIMITS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MATL TO AVOID: STRONG ACIDS: MAY REACT VIGOROUSLY. STRONG BASES: FORMS
WATER SOLUBLE ZINCATES. EFTS OF OVEREXP: & BACTERIAL TO BLOCK SWEAT
GLANDS ON THE SKIN AS A RESULT OF POOR PERSONAL HYGIENE. HNDL
G/STOR PREC: EMPTY. AVOID GENERATING DUST.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:3587F,1975C
Spec Gravity:5.65
pH:7.40
Solubility in Water:INSOLUBLE
Appearance and Odor:FINE, WHITE POWDER, ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CHLORINATED RUBBER:REACTS VIOLENTLY W/ZINC OXIDE @ 215C. MAGNESIUM:CAN
REACT EXPLOS W/ZINC OXIDES WHEN HEATED.(SUPDAT)
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:RECYCLE USED SPILL PROD IF IN ACCEPTABLE CNDTN.
OTHERWISE, DISPOSE ACCORDING TO APPLICABLE REGULATIONS &/OR CONTACT
MANUFACTURER FOR ASSISTANCE AND ADVICE CONCERNING DISPOSAL. DISPOSE
OF IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SOLVENT III
CAGE:1B637
CAGE:1B637
============= Composition/Information on Ingredients =============
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROETHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:350 PPM
ACGIH TLV:350 PPM/450STEL;9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
Effects of Overexposure:VOMIT;NAUS,DROWS;HIGH CONCENTRATIONS CAN CAUSE
ASPHYXIATION,EVEN DEATH.
======================= First Aid Measures =======================
First Aid:INHALE:REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEED.KEEP WARM
AND QUIET.CALL DR.EYE CONTACT:FLUSH W/WATER.DO NOT GIVE STIMULANTS
OF ANY KIND.
===================== Fire Fighting Measures =====================
Extinguishing Media:PRESENC IN FIRE DOES NOT HINDER USE OF ANY STANDARD
MEDIUM
Fire Fighting Procedures:USE SELF-CNTND BRTHG APP.KEEP CONTAIN COOL
WITH WATER
Unusual Fire/Explosion Hazard:VAPORS CAN BE IGNITED BY HIGH ENERGY
SOURCES.DECOMPOSES IN FIRE/ON HOT SURFACE TO ACIDIC GAS TOX:CPD
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE THE AREA,VENTILATE;CLEAN UP AREA(WEAR
PROTECTIVE CLOTHING),CONTAIN SPILL.TRANSFER BY MOPPING OR WITH
ABSORBENT MATERIAL TO STORAGE CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH SKIN AND AVOID
VAPORS.PIPE VENTS OUTDOORS.STORE IN COOL,DRY WELL-VENTILATED
AREA.NO SMOKING IN PRESENCE OF VAPORS.
Other Precautions:HALOCARBONS IN CONFINED SPACES REQUIRE
WELL-VENTILATED DRAFT AS THEY VAPORIZE READILY AND DEPLETE OXYGEN
WHICH IS NECESSARY FOR BREATHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHEN ADEQUATE VENTILATION IS USED
Ventilation:LOCAL EXHAUST SUFFICIENT TO MAINTAIN EXPOSURE BELOW TLV.
SPLASHING.
Supplemental Safety and Health
SYNONYM:METHYL CHLOROFORM.
================== Physical/Chemical Properties ==================
HCC:T4
Boiling Pt:B.P. Text:162-190F
Vapor Pres:100
Vapor Density:4.6
Spec Gravity:1.3
Evaporation Rate & Reference:0.4(ETHER=1)
Solubility in Water:MODERATE
Appearance and Odor:COLORLESS CLEAR LIQUID,MILDLY SWEET.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:OPEN FLAME,HOT SURFACES WELDING ARC
EMISSIONS
Hazardous Decomposition Products:HYDORGEN CHLORIDE,PHOSGENE AND OTHER
HIGHLY TOXIC SUBSTANCES
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT MANUFACTURER OR LOCAL POLLUTION CONTROL
AGENCY.DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND LOCAL REGS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PICRIC ACID, HT25-4
CAGE:21076
CAGE:21076
============= Composition/Information on Ingredients =============
Ingred Name:PICRIC ACID. (EC NO: 201-865-9)
CAS:88-89-1
RTECS #:TJ7875000
Other REC Limits:0.1 MG/M3 (S) MSA
OSHA PEL:0.1 MG/M3 (SKIN)
ACGIH TLV:0.1 MG/M3 (SKIN)
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: 200 MG/KG; ORAL, RAT.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE EFFECTS: HARMFUL IF SWALLOWED,
INHALED, OR ABSORBED THRU SKIN. CAUSES EYE AND SKIN IRRITATION.
MATERIAL IS IRRITATING TO MUCOUS MEMBRANES AND UPPER RESPIRATORY
TRACT. MAY CAUSE ALLERGIC RESPIR ATORY AND SKIN REACTIONS. MAY
CAUSE DISCOLORATION OF THE SKIN. TARGET ORGANS: BLOOD, KIDNEYS, AND
LIVER. TOXIC BY INHALATION, SKIN CONTACT, IF SWALLOWED. SENSITIZER.
CAUSES IRRITATION. TARGET ORGANS: BLOOD, KIDNEYS.ADDITIONAL
INFORMATION: PICRIC ACID DUST CAUSES SENSITIZATION DERMATITIS. THIS
USUALLY OCCURS ON THE FACE, ESPECIALLY AROUND THE MOUTH AND THE
SIDES OF THE NOSE; THE CONDITION PROGRES SES (SIGNS AND SYMPTOMS OF
OVEREXPOSURE)
Effects of Overexposure:HEALTH HAZARDS ACUTE AND CHRONIC (CONT): FROM
EDEMA, THROUGH THE FORMATION OF PAPULES AND VESICLES, TO ULTIMATE
DESQUAMATION. INHALATION OF HIGH CONCENTRATIONS OF DUST HAS CAUSED
UNCONSCIOUSNESS, WE AKNESS, MUSCLE PAIN, AND KIDNEY PROBLEMS.
SWALLOWING PICRIC ACID MAY CAUSE A BITTER TASTE, HEADACHE,
DIZZINESS, NAUSEA, VONITING, AND DIARRHEA. HIGH DOSES MAY CAUSE
DESTRUCTION OF THE RED BLOOD CELLSAND DAMAGE TO THE KIDNEYS AND
LIVER WITH BLOOD IN THE URINE.
======================= First Aid Measures =======================
First Aid:IN CASE OF CONTACT, IMMEDIATELY FLUSH EYES OR SKIN WITH
COPIOUS AMOUNTS OF WATER FOR AT LEAST 15 MINUTES WHILE REMOVING
CONTAMINATED CLOTHING AND SHOES. IF INHALED, REMOVE TO FRESH AIR.
IF NOT BREAT HING, GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS
DIFFICULT, GIVE OXYGEN. IF SWALLOWED, WASH OUT MOUTH WITH WATER
PROVIDED THE PERSON IS CONSCIOUS. CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY. CARBON DIOXIDE, DRY CHEMICAL POWDER OR
APPROPRIATE FOAM.
Fire Fighting Procedures:WEAR (NIOSH APPROVED - ) SELF-CONTAINED
BREATHING APPARATUS AND PROTECTIVE CLOTHING TO PREVENT CONTACT WITH
SKIN AND EYES. FLAMMABLE SOLID. USE WATER SPRAY TO COOL
FIRED-EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
MAY EXPLODE WHEN HEATED. EXPLOSIVE WHEN DRY. FORMS VERY SENSITIVE
EXPLOSIVE METALLIC COMPOUNDS. MAY BE SHOCK-SENSITIVE. FLAMMABLE
(USA DEFINITION). HIGHLY FLA MMABLE (EUROPEAN DEFINITION).RISK OF
EXPLOSION BY SHOCK, FRICTION, FIRE OR OTHER SOURCES OF IGNITION.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR SELF-CONTAINED BREATHING
A BAG AND HOLD FOR WASTE DISPOSAL. AVOID RAISING DUST. VENTILATE
AREA AND WASH SPILL SI TE AFTER MATERIAL PICKUP IS COMPLETE.
======================Handling and Storage ======================
Handling and Storage Precautions:MATERIAL MUST BE WET AT ALL TIMES.
KEEP CONTAINER TIGHTLY CLOSED. KEEP AWAY FROM SOURCES OF IGNITION
(HEAT, SPARKS, AND OPEN FLAMES). NO SMOKING. AVOID CONTACT WITH
METALS. USE ONLY IN A CHEMICAL FU ME HOOD. DO NOT BREATH DUST. DO
NOT GET IN EYES, ON SKIN, ON CLOTHING. AVOID PROLONGED (OTHER PREC)
Other Precautions:N/P. HANDLING AND STORAGE PRECAUTIONS (CONT): OR
REPEATED EXPOSURE. WASH THOROUGHLY AFTER HANDLING. STORAGE
CONDITIONS: STORE IN A COOL DRY PLACE. PURCHASE DATES SHOULD BE
MAINTAINED FOR EACH CON TAINER. MATERIAL OLDER THAN 2 YRS. SHOULD
BE DISPOSED. INSPECT AND ADD WATER EVERY SIX MONTHS AS NEE DED.
(DISPOSAL)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH-APPROVED APPROVED
RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH (MEETING ANSI
DESIGN CRITERIA - ). OTHER PROTECTIVE CLOTHING.
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE RE-USE. WASH
THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
SYNONYMS: ACIDE PICRIQUE (FRENCH), ACIDO PICRICO (ITALIAN), CARBAZOTIC
ACID, C.I. 10305, 2-HYDROXY-1,3,5-TRINITROBENZENE, KYSELINA PIKROVA
(CZECH), MELINITE, NA1344 (DOT), NITROXANTHIC ACID, PHENOL TR
INITRATE, PHENOL, 2,4,6-TRINITRO-, PICRIC ACID (ACGIH, OSHA),
PICRIC ACID, DRY OR WETTED WITH <30% WATER, (ECOLOGICAL)
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:=121.C, 249.8F
M.P/F.P Text:RANGE 121C TO 123C.
Vapor Pres:1MM 195C.
Vapor Density:7.9
Appearance and Odor:APPEARANCE: MOIST YELLOW POWDER. ODOR: NONE
SPECIFIED BY MANUFACTURER .
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG BASES, REDUCING AGENTS, HEAVY METALS,
HEAVY METAL SALTS, AMMONIA.
Stability Condition to Avoid:HEAT. CONTACT WITH METALS.
Hazardous Decomposition Products:TOXIC FUMES OF: CARBON MONOXIDE,
CARBON DIOXIDE, NITROGEN OXIDES.
=================== Toxicological Information===================
Toxicological Information:ORL-RAT LD50:200 MG/KG-JTEHD6 37,313,92.
IPR-MUS LD50:56300 UG/KG -NYKZAU 56,450,60. TARGET ORGAN DATA:
SENSE ORGANS AND SPECIAL SENSES (CHROMODACRYORRHEA). BEHAVIORAL
(TREMOR, CONVULSIONS OR EFFECT ON SEIZURE THRESHOLD). CARDIAC
(PULSE RATE DECREASED WITH FALL IN BP). LUNGS, THORAX OR
RESPIRATION (RESPIRATORY DEPRESSION, OTHER CHANGES).
GASTROINTESTINAL (HYPERMOTILITY, DIARRHEA). NUTRITIONAL AN D GROSS
METABOLIC (BODY TEMPERATURE INCREASE). ONLY SELECTED REGISTRY OF
TOXIC EFFECTS OF CHEMICAL SUBSTANCES (RTECS) DATA IS PRESENTED
HERE. SEE ACTUAL ENTRY IN RTECS FOR COMPLETE INFO.
===================== Ecological Information =====================
Ecological:DATA NOT YET AVAILABLE. SUPPLEMENTAL SAFETY AND HEALTH
(CONT): BY WEIGHT (UN0154) (DOT), PICRIC ACID, WET, WITH NOT <10%
WATER (NA1344) (DOT), PICRONITRIC ACID, PIKRINEZUUR (DUTCH),
PIKRINSAEURE (G ERMAN), PIKRYNOWY KWAS (POLISH),
2,4,6-TRINITROFENOL (DUTCH), 2.4.6-TRINITROFENOLO (ITALIAN),
TRINITROPHENOL (UN0154) (DOT), TRINITROPHENOL, WETTED WITH NOT <30%
WATER, BY WEIGHT (UN1344) (DOT), 1,3,5 -TRINITROPHENOL,
2,4,6-TRINITROPHENOL, 2,4,6-TRINITROPHENYL (OSHA), UN0154 (DOT),
UN1344 (DOT).
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT A LICENSED PROFESSIONAL WASTE DISPOSAL
SERVICE TO DISPOSE OF THIS MATERIAL. OBSERVE ALL FEDERAL, STATE AND
LOCAL ENVIRONMENTAL REGULATIONS. OTHER PRECAUTIONS (CONT): ROTATE
CONTAINERS TO DIS TRIBUTE WATER EVERY THREE MONTHS.
=================== MSDS Transport Information ===================
Transport Information:CONTACT SIGMA CHEMICAL COMPANY FOR TRANSPORT
INFORMATION. EC #: 201-865-9. FAX: USA/CANADA
1-800-325-5052; OUTSIDE USA/CANADA 314-771-5757. TELEX:
910-761-0593 OR 434475 ANSWERBACK "SIG OK COLL ECT". TEL # OUTSIDE
USA/CANADA CALL COLLECT 314-771-5750.
===================== Regulatory Information =====================
SARA Title III Information:THIS PRODUCT IS SUBJECT TO SARA SECTION 313
REPORTING REQUIREMENTS. EUROPEAN INFO: EC INDEX #: 609-009-00-X.
HIGHLY FLAMMABLE. TOXIC. R1: EXPLOSIVE WHEN DRY. R2: RISK OF
EXPLOSION BY SHOCK, FRICTION, FIRE OR OTHER SOURCES OF IGNITION.
R4:FORMS VERY SENSITIVE EXPLOSIVE METALLIC COMPOUNDS. R23/24/25:
TOXIC BY INHALATION, IN CONTACT WITH SKIN AND IF SWALLOWED. HIGHLY
FLAMMABLE. S7:KEEP CONTAINER TIGH TLY CLOSED. S16:KEEP AWAY FROM
SOURCES OF IGNITION. NO SMOKING. S26:IN CASE OF CONTACT WITH EYES,
RINSE IMMEDIATELY WITH PLENTY OF WATER AND SEEK MEDICAL ADVICE.
S36/37/39: WEAR SUITABLE PROTECTIVE CL OTHING, (FED REGS)
PROTECTION. REVIEWS, STANDARDS, & REGS: OEL=MAK. ACGIJH TLV-TWA
0.1 MG/M385INA6,1271,91. MSHA STANDARD-AIR:TWA 0.1 MG/M3 (SKIN).
OTLVS* 3,212,71. OSHA PEL (GE N INDU):8H TWA 0.1 MG/M3 (SKIN)
CFRGRB 29,1910.1000,94. OSHA PEL (CONSTRUC):8H TWA 0.1 MG/M3 (SKIN)
CFRGBR 29,1926.55,94. OSHA PEL (SHIPYARD):8H TWA 0.1 MG/M3 CFRGBR
29,1915.1000,93. OSHA PEL (FED CON T):8H TWA 0.1 MG/M3 (SKIN)
CFRGBR 41,50-204.50,94. OEL-AUSTRALIA, BELGIUM, FINLAND, UNITED
KINGDOM:T WA 0.1 MG/M3;STEL 0.3 MG/M3;SKIN JAN93. OEL-DENMARK,
FRANCE, GERMANY, HUNGARY, THE (STATE REGS)
State Regulatory Information:FED REGS (CONT): NETHERLANDS, THE
PHILLIPINES ,TURKEY:TWA 0.1 MG/M3;SKIN JAN93. OEL-:TWA 0.1
MG/M3;STEL 0.2 MG/M3;SKIN JAN93. OEL-POLAND:TWA 0.1 MG/M3 JAN93.
OEL IN BULGARIA, COLOMBIA, JORDAN, KOREA,N EW ZEALAND, SINGAPORE,
VIETNAM CHECK ACGIHTLV. NIOSH REL TO PICRIC ACID-AIR:TWA 0.1 MG/M3
(SK);STEL 0.3 MG/M3 (SK). NIOSH* DHHS #92-100,92. NOHS 1974: HZD
59450; NIS 17; TNF 2097; NOS 14; TNE 21627. N OES 1983: HZD 59450;
NIS 20; TNF 2224; NOS 26; TNE 37003; TFE 21627. EPA GENETOX PROGRAM
1988, INCON CLUSIVE: D MELANOGASTER SEX-LINKED LETHAL. EPA TSCA
SECTION 8(B) CHEM INVENTORY. EPA TSCA TEST SUBMISSION (TSCATS) DATA
BASE, APRIL 1995.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:UR-1092 #7531037
CAGE:79833
CAGE:0N414
CAGE:79833
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 36%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETONE (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 36%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TETRAHYDROFURAN (SARA III)
CAS:109-99-9
RTECS #:LU5950000
Fraction by Wt: 8%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/250 STEL
ACGIH TLV:200 PPM/250STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-CAN LEAD TO HEADCAHE, DIZZINESS,
NAUSEA & LOSS OF CONSCIOUSNESS. CHRONIC-MAY CAUSE DAMAGE TO LIVER &
KIDNEYS WHEN INGESTED OR INHALED; SEVERE EYE BURNS, DAMAGE TO
NERVOUS SYSTEM. MINOR EMBRYOTOX IC/FETOTOXIC EFFECTS HAVE BEEN
OBSERVEDIN LAB RATS EXPOSED TO MEK BY INHALATION AT LEVELS GREATER
THAN 1000 PPM.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:IRRITATION TO EYES AND MUCOUS MEMBRANES. CAN
ALSO CAUSE SKIN DRYNESS. LIQUID INGESTION MAY RESULT IN VOMITING.
WEAKNESS IN HANDS AND FEET.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF
RESPIRATORY AILMENTS, LIVER AND KIDNEY DAMAGE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH EYE ABUNDANTLY WITH CLEAN WATER & REFER TO
PHYSICIAN. SKIN-WASH WITH SOAP AND WATER. GET MEDICAL ADVICE.
INHALE-REMOVE PATIENT TO FRESH AIR OR GIVE OXYGEN. USE CPR IF
PATIENT IS NOT BREATH ING. REFER TO PHYSICIAN. INGEST-DO NOT INDUCE
VOMITING. REFER TO PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-4F,-20C
Autoignition Temp:Autoignition Temp Text:610F
Lower Limits:1.8
Upper Limits:12.8
Extinguishing Media:CARBON DIOXIDE, FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:NIOS/MSHA APPROVED SELF CONTAINED BREATHING
APPARATUS SHOULD BE WORN. COOL FIRE EXPOSED CONTAINERS WITH WATER
SPRAY & DISPERSE VAPOR CLOUD IF FIRE IS'NT PRESENT
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR & MAY TRAVEL
CONSIDERABLE DISTANCE TO SOURCE OF IGNITION AND FLASHBACK.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SPILL IN SAND, EARTH, VERMICULIT,
DRI-DRI OR SOL-SPEED-DRI. SHOVEL ABSORBED MATERIAL INTO STEEL
CONTAINER AND COVER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN APPROVED SOLVENT STORAGE
AREA. KEEP TIGHTLY CLOSE. KEEP AWAY FROM HEAT, OPEN FLAMES, SPARKS,
HOT SURFACES AND OXIDIZING AGENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED ATMOSPHERE SUPPLYING
CYLINDER OR AIR PURIFYING RESPIRATOR FOR ORGANIC VAPORS AS REQUIRED
TO MAINTAIN EXPOSURE LEVELS BELOW RECOMMENDED LIMITS.
Ventilation:LOCAL AND MECHANICAL(GENERAL) EXPLOSION-PROOF EXHAUST TO
PROVIDE ADEQUATE VENTILATION.
Other Protective Equipment:WEAR PROTECTIVE CLOTHING AS REQUIRED TO
PREVENT SKIN CONTACT.
Work Hygienic Practices:KEEP AERA CLEAN. CLEAN UP SPILLS IMMEDIATELY.
PRACTICE GOOD PERSONAL HYGIENE.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:133F,56C
Vapor Pres:127.5 MMHG
Vapor Density:2.28
Spec Gravity:0.87
Appearance and Odor:SLIGHT YELLOW CLEAR LIQUID. SWEET PUNGENT ODOR.
Percent Volatiles by Volume:5.81
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:OXIDES OF CARBON AND NITROGEN AND
SILICA.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE
FEDERAL, STATE AND LOCAL CHEMICAL AND SOLVENT WASTE DISPOSAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ABLEBOND 402
CAGE:21109
CAGE:21109
============= Composition/Information on Ingredients =============
Ingred Name:BISPHENOL A DIGLYCIDYL ETHER RESIN, EPOXY RESIN,
ARALDITE 6004, 4,4'-ISOPROPYLIDENEDIPHENOL-EPICHLOROHYDRIN
CAS:25068-38-6
RTECS #:KD4380000
Ingred Name:EPOXY RESIN
Ingred Name:VINYLCYCLOHEXENE DIOXIDE (A2 HUMAN CARCINOGEN BY ACGIH)
CAS:106-87-6
RTECS #:RN8640000
ACGIH TLV:10 PPM (SKIN) (A2)
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL (RAT) LD50: 2130 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: DERMATITIS,
SENSITIZATION, CANCER & ABSORPTION. INHALATION: HARMFUL TO THE
RESPIRATORY SYSTEM. INGESTION: TOXIC, NAUSEA, VOMITING & DIARRHEA.
Explanation of Carcinogenicity:VINYL CYCLOHEXANE DIOXIDE IS AN A2
CARCINOGEN BY ACGIH.
Effects of Overexposure:EYES: IRRITATION. SKIN: DERMATITIS,
SENSITIZATION,CANCER & ABSORPTION. INHALATION: HARMFUL TO THE
RESPIRATORY SYSTEM. INGESTION: TOXIC, NAUSEA, VOMITING, & DIARRHEA.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS. SKIN:
WASH THOROUGHLY W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR.
INGESTION: OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:225F
Extinguishing Media:CO2, FOAM & DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP W/SOLVENT SATURATED TOWELING & COLLECT
IN AN APPROPRIATE CONTAINER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE FROZEN AT ALL TIMES (-40F).
AVOID CONTACT W/SKIN, EYES & CLOTHING. AVOID INHALATION OF VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED ORGANIC VAPOR RESPIRATOR.
Ventilation:VENT CURING OVEN TO OUTDOORS. LOCAL EXHAUST.
Other Protective Equipment:PROTECTIVE EQUIPMENT
Work Hygienic Practices:USE GOOD HOUSEKEEPING.
Supplemental Safety and Health
VAPOR DENSITY, VAPOR PRESSURE, LD50 DATA IS FOR VINYL CYCLOHEXANE
DIOXIDE.
================== Physical/Chemical Properties ==================
Vapor Pres:0.1
Vapor Density:4.8
Spec Gravity:2.1
Evaporation Rate & Reference:(BU AC = 1): 0.01
Solubility in Water:SLIGHT
Appearance and Odor:BLACK PASTE
Percent Volatiles by Volume:0%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT & HEATING QUANTITIES >100
GRAMS
Hazardous Decomposition Products:CO, CO2
Conditions to Avoid Polymerization:HEATING QUANTITIES >100 GRAMS &
EXCESSIVE HEAT
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN APPROVED CHEMICAL DISPOSAL AREA OR IN
A MANNER WHICH COMPLIES W/ALL LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: EASY CLEAN UP, 051144-82878-4, 60-9800-1752-3
Cage: 1BY21
=======================================================
Contractor Summary
=======================================================
Cage: 76381
Cage: 1BY21
=======================================================
Ingredients
=======================================================
Cas: 7732-18-5
RTECS #: ZC0110000
% Wt: 55-65
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 64475-85-0
RTECS #: PY8240000
% Wt: 10-25
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 1344-28-1
RTECS #: BD1200000
% Wt: 1-20
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST
------------------------------
Cas: 8042-47-5
RTECS #: PY8047000
% Wt: 1-20
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 64742-14-9
% Wt: 5-15
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 56-81-5
RTECS #: MA8050000
% Wt: 1-10
OSHA PEL: 15 MG/M3 (MIST)
ACGIH TLV: 10 MG/M3 (MIST)
------------------------------
Cas: 110-91-8
RTECS #: QD6475000
% Wt: 0.1-1
OSHA PEL: S, 20 PPM
ACGIH TLV: S, 20 PPM
------------------------------
RTECS #: 9999999VO
SOLV:458.48 GMS/LITER
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYE CONT:MILD EYE IRRIT:SIGNS/SYMPS CAN INCLUDE REDNESS,
SWELLING, PAIN & TEARING. SKIN CONT:MILD IRRIT (AFTER PRLNGD/RPTD
CONT):SIGNS/SYMPS CAN INCLUDE REDNESS, SWELLING & ITCHING.
INHALATION:IRRITAT ION (UPPER RESPIRATORY):SIGNS/SYMPS CANINCLUDE SORENESS OF
THE NOSE & THROAT, COUGHING (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZS:& SNEEZING.
INGESTION:IRRITATION OF GASTROINTESTINAL TISSUES:SIGNS/SYMPS CAN INCLUDE
PAIN, VOMIT, ABDOM TENDERNESS, NAUS, BLOOD IN VOMIT & FECES. ASPIR
PNEUM:SIGNS/SYMPS CAN INCLUDE COUGHING , DFCLTY BRTHG, WHEEZING, COUGHING UP
BLOOD & PNEUM, WHICH CAN BE FATAL.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYE:IMMEDIATELY FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. GET IMMEDIATE MEDICAL ATTENTION. SKIN:FLUSH WITH LARGE AMOUNTS OF
WATER. IF IRRITATION PERSISTS, GET MEDICAL ATTENTION. INHAL ATION:IF
SIGNS/SYMPTOMS OCCUR, REMOVE TO FRESH AIR. IF SIGNS/SYMPTOMS CONTINUE, CALL A
PHYSICIAN. INGESTION:DO NOT INDUCE VOMITING. DRINK 2 GLASSES OF WATER. CALL A
PHYSICIAN.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: OBSERVE PRECAUTIONS FROM OTHER SECTIONS. VENTILATE
AREA. COVER WITH ABSORBENT MATERIAL. COLLECT SPILLED MATERIAL. PLACE IN AN
APPROVED METAL CONTAINER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISP MUST BE I/A/W FED, STATE & LOC REGS (FP N).
INCIN IN PERMITTED HAZ WASTE INCIN IN PRESENCE OF COMBUST MATL. DISP OF
COMPLETELY ABSORBED WASTE PROD IN HAZ WASTE FACILITY. SINCE REGS VARY,
CONSULT APPLIC REGS/AUTHS BEFORE DISP.
Handling And Storage Precautions: AVOID EYE CONTACT. DO NOT INGEST. STORE AWAY
FROM HEAT. KEEP CONTAINER CLOSED WHEN NOT IN USE. KEEP CONTAINER IN
WELL-VENTILATED AREA.
Other Precautions: KEEP AWAY FROM HEAT, SPARKS, OPEN FLAME, AND OTHER SOURCES
OF IGNITION. KEEP OUT OF THE REACH OF CHILDREN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: >200F,>93C
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). NOT DETERMINED.
Unusual Fire/Explosion Hazard: NO UNUSUAL FIRE OR EXPLOSION HAZARDS ARE
ANTICIPATED.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N). AVOID BREATHING OF VAPORS. AVOID BREATHING OF DUST.
Ventilation: PROVIDE SUFFICIENT VENTILATION TO MAINTAIN EMISSIONS BELOW
RECOMMENDED EXPOSURE LIMITS.
Other Protective Equipment: ANSI APPROVED EMERGENCY EYE WASH AND DELUGE SHOWER
(FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: PH:8.4-9.2.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 212F,100C
Vapor Density: 1
Spec Gravity: 0.96-1 (H*2O=1)
PH: SUPDAT
Evaporation Rate & Reference: >1 (ETHER=1)
Solubility in Water: NOT DETERMINED
Appearance and Odor: LIQUID; LITTLE ODOR.
Percent Volatiles by Volume: 70
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NONE.
Hazardous Decomposition Products: CARBON DIOXIDE AND CARBON MONOXIDE AND
UNIDENTIFIED HYDROCARBONS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: EASY CLEAN UP, 051144-82878-4, 60-9800-1752-3
Cage: 1BY21
Company Name: MINNESOTA MINING AND MFG CO ENGINEERING DOCUMENT SYSTEMS DIV
Street: 3M CTR
Zipcode: 55144-1000
Label Required IND: Y
Date Of Label Review: 11/06/1996
Status Code: C
Label Date: 11/06/1996
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE:EYE CONTACT:MILD EYE IRRITATION:SIGNS/SYMPTOMS
CAN INCLUDE REDNESS, SWELLING, PAIN AND TEARING. SKIN CONTACT:MILD IRRITATION
(AFTER PROLONGED OR REPEATED CONTACT):SIGNS/SYMPTOMS CAN INCLUDE REDN ESS,
SWELLING AND ITCHING. INHALATION:IRRITATION (UPPER
RESPIRATORY):SIGNS/SYMPTOMS CAN INCLUDE SORENESS OF THE NOSE AND THROAT,
COUGHING AND SNEEZING. INGESTION:IRRITATION OF GASTROINTESTINAL TISS:SI
GNS/SYMPS CAN INCLUDE PAIN, VOMIT, ABDOM TENDERNESS, NAUS, BLOOD IN VOMITUS
& FECES. ASPIR PNEUM:SIGNS/SYMPTS CAN INCLUDE COUGHING, DFCLTY BRTHG,
WHEEZING, COUGHING UP BLOOD & PNEUM, WHICH CAN BE FATA L. CHRONIC:NONE
SPECIFIED BY MANUFACTURER.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:D16180-2
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:HYDRAZINE, 1, 2-DIMETHYL-, DIHYDROCHLORIDE
CAS:306-37-6
RTECS #:MV2800000
Fraction by Wt: >99%
===================== Hazards Identification =====================
Effects of Overexposure:IRRITATING TO MUCOUS MEMBRANES, UPPER RESP.
TRACT, LIVER/KIDNEYS DAMAGE, SKIN BURNS.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/COPIOUS AMTS OF WATER AT LEAST 15 MINS
WHILE REMOVING CONTAMINATED CLOTHES/SHOES. INHALATION: REMOVE TO
FRESH AIR. IF NOT BREATHING GIVE ARTIFICIAL RESP. PREFERABLY
MOUTH-TO-MOUTH. IF BREATHING DIFFICULT GIVE OXYGEN. CALL PHYS.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY/DRY CHEMICAL/ALCOHOL/POLYMER FOAM.
Fire Fighting Procedures:WEAR SCBA/PROTECTIVE CLOTHES TO PREVENT
CONTACT W/SKIN/EYES.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR SCBA, RUBBER BOOTS/HEAVY
AVOID RAISING DUST. VENTILATE AREA/WASH SPILL SI AFTER MATERIAL
PICKUP IS COMPLETE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL DRY PLACE.
Other Precautions:DON'T BREATHE DUST. DON'T GET IN EYES, ON SKIN, ON
CLOTHING. USE ONLY IN A CHEMICAL FUME HOOD.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE OSHA/MSHA-APPROVED RESPIRATOR.
Ventilation:USE WITH ADEQUATE VENTILATION
Supplemental Safety and Health
MSDS DATE: 6/6/86
================= Stability and Reactivity Data =================
OXIDIZING AGENTS, BASES
Hazardous Decomposition Products:NOX, HYDROGEN CHLORIDE GAS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE OR MIX THE MATERIAL WITH A COMBUSTIBLE
SOLVENT & BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AN SCRUBBER. OBSERVE ALL FEDERAL, STATE & LOCAL LAWS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CRAYOLA WASHABLE PAINT, 54-0105 034-YELLOW
CAGE:85419
CAGE:85419
============= Composition/Information on Ingredients =============
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS
CAS:14807-96-6
RTECS #:WW2710000
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:CLAY (KAOLIN); (KAOLIN)
CAS:1332-58-7
RTECS #:GF1670500
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: NONE KNOWN. CHRONIC: NONE
KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.
CONTACT A PHYSICIAN. SKIN: WASH THOROUGHLY WITH SOAP AND WATER.
INGESTION: DO NOT INDUCE VOMITING. CONTACT A PHYSICIAN OR POISON
CONTROL CENTE R. INHALATION: REMOVE PERSON TO FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:WATER, FOAM, CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE TO CONTAIN SPILL. KEEP OUT OF SEWERS AND
WATERCOURSES. ABSORB WITH INERT MATERIAL AND PLACE IN CONTAINER FOR
DISPOSAL. FLUSH RESIDUAL WITH COPIOUS AMOUNTS OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NOT REQUIRED.
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:CLEAN, SAFE WORK PRACTICES.
Supplemental Safety and Health
SPEC GRAV: 1.19-1.31 (H*2O=1).
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>215F,>102C
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Vapor Density:<1
Spec Gravity:SUPDAT
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:DISPERSES
Appearance and Odor:VARIOUS COLORS; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY PRODUCE
CARBON MONOXIDE AND CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:M38-15 THRUST QUICK START FLUID
Preparer's Name:I. LIEBERMAN
CAGE:77628
CAGE:77628
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ETHER (SARA III)
CAS:60-29-7
RTECS #:KI5775000
Fraction by Wt: 35-50%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400PPM/500STEL; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:N-HEPTANE
CAS:142-82-5
RTECS #:MI7700000
Fraction by Wt: 50-65%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9293
Ingred Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM/30000STEL;93
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION OF VAPORS MAY CAUSE
CENTRAL NERVOUS SYSTEM DEPRESSION. CONTACT WITH SKIN AND EYES MAY
CAUSE IRRITATION. INGESTION MAY BE HARMFUL OR FATAL. CHRONIC: NONE
SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NO INGREDIENTS OF A CONCENTRATION OF
0.1% ORGREATER ARE LISTED AS A CARCINOGEN BY NTP, IARC, OR OSHA.
Effects of Overexposure:INHALED: HEADACHE, DIZZINESS, NARCOSIS,
UNCONSCIOUSNESS. SKIN: RASH, DISCOMFORT. EYES: TEARING, REDNESS,
DISCOMFORT. INGESTED: NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALED: MOVE TO FRESH AIR. GIVE ARTIFICIAL RESPIRATION IF
BREATHING STOPPED. GIVE OXYGEN IF BREATHING DIFFICULT. SEE DOCTOR.
EYES: FLUSH WITH LOTS OF WATER FOR 15 MINUTES. SKIN: REMOVE
CONTAMINATED C LOTHES. WASH WITH SOAP AND WATER. INGESTED: DO NOT
INDUCE VOMITING! DO NOT GIVE EPINEPHRINE OR ADRENILIN! GET
IMMEDIATE MEDICAL ATTENTION!
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:<20F,<-7C
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS. USE
WATER SPRAY TO COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:AT ELEVATED TEMPERATURES CONTAINERS MAY
VENT, RUPTURE OR BURST, EVEN VIOLENTLY. CONTENTS UNDER PRESSURE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. ELIMINATE ALL SOURCES OF
IGNITION. ABSORB WITH INERT MATERIAL OR WIPE UP. PLACE IN A
CONTAINER FOR LATER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE BELOW 120F;
AWAY FROM IGNITION SOURCES, STRONG OXIDIZING AGENTS, STRONG MINERAL
ACIDS, AND STRONG ALKALIS.
Other Precautions:WEARING OF CONTACT LENSES IS NOT RECOMMENDED. KEEP
AWAY FROM CHILDREN AND ANIMALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. IF TLV EXCEEDED, USE
NIOSH/MSHA APPROVED RESPIRATOR. USE IN ACCORDANCE WITH 29 CFR
1910.134.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION.
Other Protective Equipment:APRON
Work Hygienic Practices:WASH HANDA AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V3
Spec Gravity:0.67 (WATER=1)
pH:6-7
Evaporation Rate & Reference:N/K (N-BUTYL ACETATE=1)
Solubility in Water:MODERATE
Appearance and Odor:COLORLESS VOLATILE LIQUID
Percent Volatiles by Volume:95
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG MINERAL ACIDS, STRONG ALKALIS
Stability Condition to Avoid:CONTACT WITH INCOMPATIBLE MATERIALS. HIGH
TEMPERATURES.
Hazardous Decomposition Products:NORMAL PRODUCTS OF COMBUSTION;CARBON
MONOXIDE AND CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. DO NOT INCINERATE.
| 1 | gloves_mandatory |
=======================================================
Product ID: 04024 DOUBLE BUBBLE PURPLE/BEIGE A85
Kit Part: Y
Cage: 96900
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 96900
=======================================================
Contractor Summary
=======================================================
Cage: 96900
=======================================================
Ingredients
=======================================================
Cas: 85-68-7
RTECS #: TH9990000
1,2-BENZENEDICARBOXYLIC ACID, BUTYL PHENYLMETHYL ESTER
% Wt: 20-50
Other REC Limits: 5 MG/CUM
EPA Rpt Qty: 100 LBS
DOT Rpt Qty: 100 LBS
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: ORAL LD50(RAT): 485 MG/KG
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES: MODERATE IRRITATION. INGESTION: TOXIC. SKIN: MILD
IRRITANT & ABSORPTION.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: IRRITATION.
First Aid: INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN IF NEEDED. EYES: FLUSH
THOROUGHLY W/WATER FOR 15 MINS. INGESTION: INDUCE VOMITING IMMEDIATELY. DON'T
GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. SKIN: WASH W/SOAP &
WATER FOR 15 MINS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SHUT OFF IGNITION SOURCES & DIKE TO CONTAIN &
PREVENT ENTRY INTO SEWERS/WATER SOURCES. ABSORB MATERIAL & PLACE IN
CLOSED CONTAINER FOR DISPOSAL.
Waste Disposal Methods: CONTROLLED INCINERATION, IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point Text: 280F
Lower Limits: 0.26
Upper Limits: 0.00
Extinguishing Media: WATER SPRAY, DRY CHEMICAL, FOAM, CO2.
Fire Fighting Procedures: AVOID BREATHING SMOKE & VAPORS.
=======================================================
Control Measures
=======================================================
Respiratory Protection: FOR EMERGENCIES, A POSITIVE PRESSURE BREATHING
APPARATUS/A FULL FACE RESPIRATOR W/AN APPROVED ORGANIC CANISTER IS
RECOMMENDED.
Ventilation: LOCAL EXHAUST RECOMMENDED.
Other Protective Equipment: CHEMICAL SPLASH APRON.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: NONE
Vapor Density: >1
Evaporation Rate & Reference: (N-BU AC =1): 1
Appearance and Odor: LIQUID
Percent Volatiles by Volume: 0.0
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Hazardous Decomposition Products: CO, CO2, NITROGEN OXIDES, AMMONIA.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: 04024 DOUBLE BUBBLE PURPLE/BEIGE A85
Cage: 96900
Company Name: HARDMAN INC
Street: 600 CORTLANDT ST
Zipcode: 07109-3328
Label Required IND: Y
Date Of Label Review: 10/12/1999
Status Code: A
Origination Code: G
Hazard And Precautions: EYES: MODERATE IRRITATION. INGESTION: TOXIC. SKIN: MILD
IRRITANT & ABSORPTION.
=======================================================
| 1 | gloves_mandatory |
=======================================================
Product ID: D79011, SINGLE ELEMENT SOLUTION STANDARD, (SUPP DATA)
Cage: IO225
=======================================================
Contractor Summary
=======================================================
Cage: IO225
Cage: 0L438
=======================================================
Ingredients
=======================================================
Cas: 7400-57-5
RTECS #: MD5070000
% Wt: 0.1-1
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Cas: 7647-01-0
RTECS #: MW4025000
% Wt: 10
OSHA PEL: 5 PPM, C
ACGIH TLV: 5 PPM, C
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 7732-18-5
RTECS #: ZC0110000
% Wt: 90
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: SKIN/EYE IRRITATION OR INFLAMMATION. IRRITATION OF MUCOUS
MEMBRANES.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SKIN/EYE IRRITATION OR INFLAMMATION.
Medical Cond Aggravated By Exposure: NONE.
First Aid: SEEK MEDICAL ASSISTANCE FOR FURTHER ASSISTANCE. EYES:FLUSH W/WATER
FOR AT LEAST 15 MINUTES. SKIN:FLUSH W/WATER FOR 15 MINUTES. WASH CONTAMINATED
CLOTHING BEFORE RE-USE. INHAL:REMOVE TO FRESH AIR. INGE ST:DO NOT INDUCE
VOMITING. GIVE WATER OR MILK.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: TAKE UP W/INERT, ABSORBENT MATERIAL. CONTAINERIZE FOR
DISPOSAL. FLUSH SPILL AREA W/WATER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: CORROSIVE WASTE I/A/W ALL FEDERAL, STATE & LOCAL
ENVIRONMENTAL REGULATIONS.
Handling And Storage Precautions: STORE IN COOL, DRY PLACE. KEEP CONTAINER
SEALED. HYDROCHLORIC ACID - POISON.
Other Precautions: NO OTHER SPECIAL PRECAUTIONS OR HAZARDS.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: WATER OR CO*2.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH APPROVED RESPIRATORY PROTECTION, WHEN NEEDED.
Ventilation: NONE REQUIRED. LOCAL EXHAUST, WHEN NEEDED.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N). LAB COAT.
Work Hygienic Practices: USUAL.
Supplemental Safety and Health: MFR'S TRADE NAME/PART NO:GOLD, HYDROCHLORIC
ACID MATRIX. EYE PROT:& FULL LENGTH FACESHIELD (FP N).
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 212F,100C
Spec Gravity: 1 (H*2O=1)
Evaporation Rate & Reference: H*2O=1
Solubility in Water: SOLUBLE
Appearance and Odor: CLEAR, YELLOW TO DARK YELLOW SOLUTION; NO ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: EXCESSIVE HEAT OR EXTREME COLD.
Materials To Avoid: STRONG BASES OR STRONG REDUCING AGENTS.
Hazardous Decomposition Products: CL-.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: D79011, SINGLE ELEMENT SOLUTION STANDARD, (SUPP DATA)
Cage: IO225
Assigned IND: Y
Company Name: PLASMA CHEM CORP
Street: 5142 WEST HURLEY POND ROAD
Zipcode: 07727
Label Required IND: Y
Date Of Label Review: 01/06/1997
Status Code: C
Label Date: 01/06/1997
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: Slight
Hazard And Precautions: DECOMPOSITION PRODUCTS MAY BE HARMFUL. CORROSIVE.
ACUTE:SKIN/EYE IRRITATION OR INFLAMMATION. IRRITATION OF MUCOUS MEMBRANES.
CHRONIC:NONE LISTED BY MANUFACTURER.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1600 BLENDZ-ALL/COLOR BLEND SOLNT/532-0551
CAGE:EO878
CAGE:EO878
CAGE:90608
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE (SEE SUPPLEMENTAL FOR INGREDIENTS)
CAS:2921-14-4
RTECS #:AF3150000
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PROPYLENE GLYCOL MONOMETHYL ETHER ACETATE
CAS:108-65-6
RTECS #:AI8925000
===================== Hazards Identification =====================
Effects of Overexposure:INHALATION:
HEADACHE/NAUSEA/DIZZINESS/WEAKNESS/FATIGUE/UNCONSCIOUSNESS. EYE:
SEVERE IRRITANT.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING IS
DIFFICULT/OXYGEN. EYE: FLUSH W/WATER FOR AT LEAST 15 MINUTES. SKIN:
WASH AFFECTED AREAS W/SOAP & WATER. REMOVE SOILED CLOTHING.
INGESTION: DON'T INDUCE VOMITING. CONSULT A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:14F T.C.C.
Lower Limits:0.9%
Upper Limits:36%
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:USE SCBA. WATER COOL CONTAINERS TO PREVENT
PRESSURE BUILDUP.
Unusual Fire/Explosion Hazard:EXTINGUISH ALL PILOT LGTS, TURN OFF
HEATERS/NON-EXPLOSION PROOF ELECTRICAL EQUIP/SOURCES OF IGNITION
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION(FLAMES/HOT
SURFACES/ELECT. STATIC/FRICTIONAL SPARKS).VOID BREATHING VAPOR.
VENTILATE AREA. WEAR APPROPRIATE RESP/PROTECTIVE CTHING.
DIKE/CONTAIN SPILLED MATERIAL/REMOVE W/INERT ABSORBENT/NON-SPARKI
TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS, OPEN
FLAME. USE WITH ADEQUATE VENTILATION. DON'T BREATHE VAPORS. N'T GET
IN EYE, ON SKIN OR CLOTHING.
Other Precautions:NEVER USE CUTTING OR WELDING TORCH IN, ON OR NEAR
CONTAINERS, EVEN EMPTY, AS PRODUCT OR RESIDUE MAY IGNITE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED SCBA.
Ventilation:PROVIDE MECH/LOCAL EXHAUST VENTILATION TO KEEP BELOW TLV
Other Protective Equipment:EYE BATH AND SAFETY SHOWER.
Supplemental Safety and Health
MSDS DATE: 1/20/86. GS-295 HYDROCARBON PET. DISTILLATE OR NAPHTHA
(1001042NA)/ISOPROPYL ALCOHOL (NT8050000)/METHANOL
(PC14000)/DIBASIC ESTERS (DIMETHYL SUCCINATE/GLUTARATE)
(1000540DA).
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:143-391F
Vapor Pres:68
Vapor Density:2.93
Spec Gravity:0.8203
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:55%
Appearance and Odor:WATER WHITE LIQUID.
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:MAY YIELD CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE UNDER SAFE CONDITIONS OR DISPOSE OF
IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:636 ORIENTAL RED ACRYLIC GLOSS EXTERIOR PAINT
Resp. Party Other MSDS Num.:90006001
CAGE:50411
CAGE:50411
============= Composition/Information on Ingredients =============
Ingred Name:PROPYLENE GLYCOL; VP: 0.22 MMHG @ 20C OCCUPATIONAL
EXPOSURE LIMIT (PPM): 50 RECOMMENDED.
CAS:57-55-6
RTECS #:TY2000000
= Wt:11.
Other REC Limits:50 PPM (MFR)
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:2-BUTOXYETHANOL; VP: 0.8 MMHG @ 20C
CAS:111-76-2
RTECS #:KJ8575000
= Wt:1.
Other REC Limits:N/K
OSHA PEL:240 MG/M3;50 PPM
OSHA STEL:N/K
ACGIH TLV:121 MG/M3;25 PPM
ACGIH STEL:N/K
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:EFFECTS OF OVEREXPOSURE: INHALATION:
IRRITATION OF THE RESPIRATORY TRACT OR ACUTE NERVOUS SYSTEM CAUSING
HEADACHE, DIZZINESS, NAUSEA. ACUTE: EYE AND SKIN: PRIMARY
IRRITATION. MAY CAUSE AN ALLERGIC SKI N OR RESPIRATORY REACTION IN
PEOPLE WHOARE SENSITIVE (ALLERGIC) TO ACRYLIC POLYMERS. INHALATION
OF SOLVENT VAPOR MAY CAUSE IRRITATION TO THE NOSE, THROAT, AND
RESPIRATORY. ANIMAL STUDIES CLEARLY DEMON STRATED DOSE-RELATED
ADVERSE EFFECTS ON THE CNS, HEMATOPOIETIC TISSUE, BLOOD, KIDNEYS,
AND LIVER, ASSOCIATED WITH THE ADMINISTRATION OF 2-BUTOXYETHANOL
(EXTRACTED FROM DHHS (NIOSH) PUBLICATION #90-118 ) .
Explanation of Carcinogenicity:FORMALDEHYDE: IARC MONOGRAPHS,
SUPPLEMENT, VOLUME 47, PAGE 171, 1998: GROUP 2B. NTP 8TH ANNUAL
REPORT ON CARCINOGENS, 1998: REASONABLY ANTICIPATED TO BE HUMAN
CARCINOGEN. OSHA REGULATED: CFR 29 1910.1 048. ANIMAL: NASAL
TUMORS.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN, EYE AND LUNG
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO 2-BUTOXYETHANOL.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE. KEEP WARM AND QUIET. NOTIFY
PHYSICIAN. EYES: FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF WATER FOR
AT LEAST 15 MINUTES. TAKE TO PHYSICIAN FOR MEDICAL TREATMENT. SKIN:
WAS H AFFECTED AREA WITH LARGE AMOUNTS OF WATER. REMOVE
CONTAMINATED CLOTHING. INGESTION: CALL A PHYSICIAN IMMEDIATELY .
===================== Fire Fighting Measures =====================
Lower Limits:0.7%-1.0%
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . IN THE ABSENCE OF ELECTRICITY, A WATER SPRAY (FOG
NOZZLE IS PREFERRED) MAY BE USED TO COOL CONTAINERS. AVOID EXPOS TO
DECOMPOSITION. REFER TO D.O.T. P 5800.3 "1984 EMERGENCY RESPONSE
BOOK: GUIDEBOOK FOR HAZARDOUS MATERIALS' INCIDENTS" GUIDE # 26, ID
# 1263.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, SPARKS, ELECTRICAL EQUIPMENT, AND OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT. FLAMMABILITY
CLASSIFICATION: OSHA: N/A; DOT : N/A.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION (FLAMES, HOT
SURFACES, AND ELECTRICAL, STATIC OR FRICTION SPARKS). AVOID
BREATHING VAPORS, WEAR NIOSH APPROVED RESPIRATOR, AND VENTILATE
AREA. REMOVE WITH INERT ABSORBEN T SUCH AS SAND, KITTY LITTER, ETC,
AND USE NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:SECURE CLOSURES & KEEP CONTRS UPRIGHT
TO PVNT LEAKAGE. STORE LGE QTYS ONLY IN BLDGS DESIGNED TO COMPLY
W/OSHA 1910.106. DO NOT STORE ABOVE 120F. DO NOT TAKE INTERNALLY.
DO NOT GET IN EYES/ON SKIN. AVO ID BRTHG VAPS/SPRAY MIST. DO NOT
STORE/USE NEAR HEAT.
Other Precautions:DO NOT FLAME CUT, BRAZE/WELD W/OUT NIOSH APPRVD MECH
FILTER RESP/APPROP & ADEQ VENT. ALL ELEC EQUIP & INSTALLATIONS
SHOULD BE MADE & GROUNDED I/A/W NATL ELEC CODE. IF WORKMEN ARE
EXPOSED TO SPRAY APPL ICATION/ABRASIVE BLAST CLEANING, ENGINEERING
& ADMIN CTLS MUST BE USED TO MAINTAIN EXPOS LEVEL BELOW OSHA (SUP
DAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN OUTDOOR/OPEN AREAS W/UNRESTRICTED VENT, USE
NIOSH APPROVED MECHANICAL FILTER RESPIRATOR TO REMOVE SOLID
AIRBORNE PARTICLES OF OVERSPRAY DURING SPRAY APPLICATION. IN
RESTRICTED VENT AREAS, USE NIOSH APPROVED MECHANICAL FILTER
RESPIRATORS DESIGNED TO REMOVE PARTICULATES, GAS & VAPOR. IN
CONFINED AREAS, USE NIOSH APPROVED AIR-LINE RESPIRATORS & HOODS.
Ventilation:PROVIDE GEN DILUTION/LOC EXHST VENT IN VOL & PATTERN TO
KEEP TLV BELOW STATED OSHA LIMITS & LEL BELOW STATED LIM & TO
REMOVE DECOMP PRODS DURING (SUP DAT)
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER . AS NEEDED, USE BODY PROTECTION, SUCH AS RUBBER APRON, ETC.
Work Hygienic Practices:BEFORE SMOKING OR EATING, WASH HANDS
THOROUGHLY.
Supplemental Safety and Health
OTHER PREC: REQUIRED LEVEL/USE NIOSH APPRVD MECH FILTER RESP FOR PROT.
VENT: WELDING & FLAME CUTTING OF SURFACES COATED W/THIS PROD.
PHYSICAL/CHEM PROPERTIES: WEIGHT PER GALLON: 8.7 - 9.9 LBS.
================== Physical/Chemical Properties ==================
Boiling Pt:=100.C, 212.F
Vapor Pres:SEE INGREDIENTS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:63-70
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO DECOMPOSITION AS IN WELDING. FUMES MAY PRODUCE CARBON
DIOXIDE AND CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A SAFE MANNER IN ACCORDANCE WITH
LOCAL, STATE, AND FEDERAL REGULATIONS THAT APPLY TO INCINERATION OR
SECURE LANDFILL.
===================== Regulatory Information =====================
State Regulatory Information:WARNING: THESE PRODUCTS CONTAIN
FORMALDEHYDE
WHICH IS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:COPPER(II)SULFATE PENTAHYDRATE;BLUE VITRIOL
CAGE:62910
CAGE:62910
============= Composition/Information on Ingredients =============
Ingred Name:COPPER SULFATE(PENTAHYDRATE)BLUE VITRIOL.CAS#7758-99-8
CAS:7758-99-8
RTECS #:GL8900000
Fraction by Wt: 100%
ACGIH TLV:1MG/CUM(AS CU)
===================== Hazards Identification =====================
Effects of Overexposure:INHAL:IRRITATION TO UPPER RESPIRATORY
TRACT,COLD,CHILL,COUGHING;SKIN:IRRITATION ITCHING.SEE SUP DATA
======================= First Aid Measures =======================
First Aid:INHALE:REMOVE TO FRESH AIR, GIVE CPR/O*2 IF
NEED;EYES/SKIN:FLUSH W LG AMTS H*2O FOR 15 MIN;INGEST:RINSE MOUTH;
GET MEDICAL ATTENTION FOR EYES, BREATHING DIFFICULTY, OR OTHER
SYMPTOMS OF OVEREXPOSURE.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NOT CONSIDERED TO BE FIRE HAZARD.
Fire Fighting Procedures:USE ANY MEANS.WATERSPRAY MAY BE USED.USE SCBA
IN FIRES.
Unusual Fire/Explosion Hazard:NO EXPLOSION HAZARDS.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION.PICK UP/SWEEP
UP AND RECOVER IN A SUITABLE CONTAINER FOR PROPER DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY AND VENTILATED
AREA.PROTECT FROM PHYSICAL DAMAGE AND ISOLATE FROM INCOMPATIBLE
SUBSTANCES.SOULTIONS ARE CORROSIVE TO MILD STEEL.
Other Precautions:AVOID CONTACT WITH EYES AND SKIN.DO NOT
SWALLOW,POISONOUS SUBSTANCE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR
DUST/MIST.
Ventilation:LOCAL EXHAUST TO MAINTN BELOW TLV.
Other Protective Equipment:FULL PROTECTIVE CLOTHING,SAFETY SHOWER,EYE
WASH STATION
Supplemental Safety and Health
MSDS DATED
08/05/85.EFFECTS/OVEREXPOSURE:EYES;IRRITATION,ULCERATION,CLOUDING
OF THE CORNEA;INGESTION:PAIN IN STOMACH,NAUSEA,VOMITING,POISONING
OF COPPER,HEADACHE,COLD SWEAT,WEAK PULSE ETC.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:752F/400C+D
Spec Gravity:2.28
Evaporation Rate & Reference:<1.0 (WATER=1)
Solubility in Water:APPRECIABLE
Appearance and Odor:TRANSPARENT BLUE TRICLINIC CRYSTALS,GRANULES/POWDE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HIGH TEMP >250C,MAGNESIUM
Stability Condition to Avoid:NONE SPECIFIED.
Hazardous Decomposition Products:WHEN HEATED TO DECOMPOSITION CUPRIC
OXIDE AND SULFUR OXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF COLLECTED MATERIAL IN ACCORDANCE WITH
LOCAL,STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CUT-THRU, 1740
Preparer's Name:MARK COHEN
CAGE:0A649
CAGE:0A649
CAGE:53417
============= Composition/Information on Ingredients =============
Ingred Name:CYCLOHEXENE, 1-METHYL-4-(1-METHYLETHENYL)-, (R)-;
(D-LIMONENE). LD50:(ORAL,RAT) 4400 MG/KG.
CAS:5989-27-5
RTECS #:GW6360000
Ingred Name:HEXYLENE GLYCOL
CAS:107-41-5
RTECS #:SA0810000
OSHA PEL:C 25 PPM
ACGIH TLV:C 25 PPM; 9192
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY BE IRRIT TO EYES & SKIN.
MILD, LOCAL IRRIT & SENSIT MAY CAUSE DEFATTING OF SKIN. INGESTION
OF LRG QTYS CAN CAUSE DIZZ, NAUSEA, CRAMPS, VOMITING, DIARRHEA &
MAY BE ABSORBED. ASPIRATION OF MA TL INTO LUNGS CAN CAUSE CHEMICAL
PNEUMONITIS WHICH CAN LEAD TO NASAL AND RESP IRRIT. SORE THROAT,
(SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: COUGHING, SHORTNESS OF BREATH,
DIZZINESS AND NAUSEA. CHRONIC: MARKED IRRITATION TO EYES. EXCESSIVE
OVEREXPOSURE TO THE SKIN CAN CAUSE DERMATITIS AND CHAPPING. TARGET
ORGAN EFFECT: REPEATED D AILY ORAL DOSING OF LARGE AMOUNTS TO RATS
& DOGS CAUSES KIDNEY EFFECTS. EXCESSIVE OVEREXP MAY RESULT IN
SIMILAR EFFECTS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: GENERALLY NOT A HAZ. REMOVE TO FRESH AIR & PROVIDE
SUPPORTIVE MEASURES. EYE: FLUSH W/H2O FOR AT LEAST 15 MIN HOLDING
LIDS WIDE OPEN. SEE MD IF IRRIT PERSISTS. SKIN: TYPICALLY NOT A
HAZ. WASH OF F W/SOAP & H2O & APPLY AN EMOLLIENT RICH CREAM.
INGEST: GIVE 2 GLASSES OF H2O. DO NOT INDUCE VOMIT. SEE MD. NOTE TO
MD: GASTRIC LAVAGE IS INDICATED. ALBUMINURIA & HEMATURIA ARE
PROBABLE (SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:119F,48C
Lower Limits:0.7 %
Upper Limits:6.1 %
Extinguishing Media:FOAM, CO2, DRY CHEMICAL OR WATER SPRAY.
Fire Fighting Procedures:AS WITH ANY SOLVENT FIRE, WEAR NIOSH/MSHA
APPROVED SCBA AND FULL PROTECTIVE EQUIP WHEN IN CONFINED AREA TO
PROTECT FROM ACRID SMOKE AND HAZ DECOMP PROD.
Unusual Fire/Explosion Hazard:CAN REACT VIOLENTLY WITH IF3 IN
COMBINATION WITH TETRAFLUOROETHYLENE.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL. PICK UP AND REUSE IF POSSIBLE.
PLACE INTO LABELED CONTAINERS FOR PROPER DISPOSAL.
Neutralizing Agent:WATER WILL EMULSIFY PRODUCT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE TEMP: MAX 100 F, MIN 35 F.
KEEP OUT OF EYES. KEEP AWAY FROM HEAT & FLAME. USE WITH ADEQUATE
VENT. KEEP CNTNRS TIGHTLY CLOSED WHEN NOT IN USE.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. READ ENTIRE LABEL
BEFORE USING PROD.
============= Exposure Controls/Personal Protection =============
Ventilation:GENERAL EXHAUST ADEQUATE TO PROTECT WORKER FROM EXPOSURE TO
LEVELS ABOVE PERMISSIBLE EXPOSURE LIMITS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: IF INGESTED IN SUFFICIENT QUANTITY.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:378F,192C
Vapor Pres:5
Vapor Density:6
Spec Gravity:0.85
pH:8.5
Evaporation Rate & Reference:0.01 (BUTYL ACETATE=1)
Solubility in Water:EMULSION
Appearance and Odor:TRANSPARENT, ORANGE, WITH ORANGE ODOR.
Percent Volatiles by Volume:< 3
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS. AVOID ACIDIC CLAYS AND MINERAL ACIDS.
Stability Condition to Avoid:AVOID HEAT, SPARKS OR OPEN FLAMES.
Hazardous Decomposition Products:CARBON MONOXIDE UPON BURNING AS WELL
AS SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE
AND LOCAL POLLUTION CONTROL AUTHORITIES. INCINERATION IS GENERALLY
THE PREFERRED METHOD OF DISPOSAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:GO-JO HEAVY DUTY HAND CLEANER WITH FINE ITALIAN PUMICE
Preparer's Name:RONALD A. WILLIAMS
CAGE:02905
CAGE:70842
CAGE:02905
CAGE:050Q3
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL, WHITE
CAS:8042-47-5
RTECS #:PY8047000
Fraction by Wt: <50%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NONIONIC SURFACTANTS
Fraction by Wt: <10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SCRUBBING PARTICLES
Fraction by Wt: <10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:PROPYLENE GLYCOL
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: <10%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NONE KNOWN.
Effects of Overexposure:EYE CONTACT-IRRITATION. INGESTION-GASTRIC
DISTRESS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:EYE CONTACT-DO NOT RUB EYES, FLUSH WITH WATER FOR 15 MINUTES,
IF IRRITATION PERSISTS, CONTACT PHYSICIAN OR POISON CONTROL CENTER.
INGESTION-DO NOT INDUCE VOMITING. CONTAINS MINERAL OIL. CONTACT
PHYSIC IAN OR POISON CONTROL CENTER IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>200F,>93C
Autoignition Temp:Autoignition Temp Text:NA
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:WATER FOG, ALCOHOL FOAM, CARBON DIOXIDE, DRY
CHEMICAL.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB AND COLLECT FOR DISPOSAL. FLUSH AREA
WITH WATER TO REDUCE POSSIBLE FLOOR "SLIP" HAZARD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID EYE CONTACT; STORE AT AMBIENT
CONDITIONS.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED.
Ventilation:NONE REQUIRED.
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:ROUTINE.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:ND
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:ND
Vapor Density:ND
Spec Gravity:0.88
Evaporation Rate & Reference:ND
Solubility in Water:CA 45%
Appearance and Odor:YELLOW GEL, PLESANT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:ACCORDING TO ALL LOCAL, STATE AND FEDERAL
REGULATIONS.
| 0 | gloves_not_mandatory |
=======================================================
NIIN: 01-381-3410
Product ID: BLAST OFF RUST 55 GALLON DRUM, H-4
Cage: 52790
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 52790
=======================================================
Item Description Information
=======================================================
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: NAUSEA MAY OCCUR WHEN TAKEN INTERNALLY-NOT TOXIC. NAUSEA
OR DIZZINESS MAY OCCUR BUT WOULD BE EXTREMELY RARE. COULD IRRITATE MUC MEMBS.
WEAR OSHA/NIOSH/MSHA APPROVED FACE MASK IF EXPOSED TO MATL FOR LO NG PERIODS
OF TIME. ALTHOUGH PROD IS INHIBITED & CORROSION CONTROLLED, PRLNGD EXPOS
WILL CAUSE DRYING OF SKIN & IRRIT.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: COULD CAUSE SLIGHT SKIN RASH IF
OVEREXPOSURE OCCURS. COULD CAUSE EYE DAMAGE BY EXTENDED CONTACT.
First Aid: INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP)
(FP N). EYES:IMMEDIATELY FLUSH W/POTABLE WATER FOR A MINIMUM OF 15 MINUTES,
SEEK ASSISTANCE FROM MD (FP N). INGEST:DRINK COPIOUS AMOUN TS OF WATER.
SKIN:USE REGULAR SOAP OR PLAIN WATER TO WASH MATERIAL OFF SKIN OR CLOTHING.
GET MEDICAL ATTENTION IF IRRITATION OR SYMPTOMS SEEM AGGRAVATED.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: ABSORB SPILLS WITH DRY SAND OR EARTH, THEN PLACE IN
CHEMICAL WASTE CONTAINER FOR DISPOSAL. FLUSH RESIDUAL AREA WITH WATER.
Neutralizing Agent: WATER, SODA ASH OR OTHER ALKALINE PRODUCTS.
Waste Disposal Methods: DISPOSE OF ACCORDING TO LOCAL, STATE OR FEDERAL LAWS.
REMEMBER SOME STATES ABSOLUTELY FORBID ANYTHING EXCEPT RAINWATER TO GO INTO
DRAINAGE SYSTEMS.
Handling And Storage Precautions: STORE IN PLASTIC, RUBBER LINED, OR 316
STAINLESS STEEL CONTAINERS. STORE AWAY FROM EXTREME HEAT. DO NOT GET IN EYES,
ON SKIN OR CLOTHING.
Other Precautions: AVOID BREATHING MIST. KEEP CONTAINER CLOSED. KEEP OUT OF
REACH OF CHILDREN. USE WITH ADEQUATE VENTILATION.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: OC
Flash Point Text: NONE
Extinguishing Media: MEDIA SUITABLE FOR SURROUNDING FIRE (FP N).
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
=======================================================
Control Measures
=======================================================
Respiratory Protection: AVOID BREATHING MIST. IF PRODUCT IS BEING SPRAYED WEAR
NIOSH/MSHA APPROVED MASK.
Ventilation: USE WITH ADEQUATE VENTILATION.
Other Protective Equipment: IF SPRAYING IN WINDY SITUATION WEAR CHEMICAL
RESISTANT CLOTHING.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: SPEC GRAV:1.11/12.05 BE' (H*2O=1).
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 270F,132C
M.P/F.P Text: 25.0F,-3.9C
Vapor Pres: 850 MM/HG
Spec Gravity: SUPP DATA
PH: 1.8
Evaporation Rate & Reference: 1.42 (H*2O=1)
Solubility in Water: 99.8% BY WEIGHT
Appearance and Odor: PURPLE & VISCOUS, LILAC ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: ALKALINE, SULFIDES AND SULFIDE PRODUCTS.
Hazardous Decomposition Products: NONE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 131824
Product ID: BLAST OFF RUST 55 GALLON DRUM, H-4
Review Date: 09/11/1995
Multiple KIT Number: 0
Review IND: Y
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: BLAST OFF RUST 55 GALLON DRUM, H-4
Cage: 52790
Company Name: ELSCO INTERNATIONAL
Street: 3407 E ST
Zipcode: 92102
Label Required IND: Y
Date Of Label Review: 04/05/1995
Status Code: C
Label Date: 04/05/1995
Origination Code: G
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Severe
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE:NAUSEA MAY OCCUR WHEN TAKEN INTERNALLY-NOT TOXIC.
NAUSEA OR DIZZINESS MAY OCCUR BUT WOULD BE EXTREMELY RARE. COULD IRRITATE THE
MUCOUS MEMBRANES. WEAR OSHA/NIOSH/MSHA APPROVED FACE MASK IF EXPOS ED TO MATL
FOR LONG PERIODS OF TIME. ALTHOUGH PRODUCT IS INHIBITED & CORROSION
CONTROLLED, PROLONGED EXPOSURE WILL CAUSE DRYING OF SKIN AND IRRITATION.
CHRONIC:NONE LISTED BY MANUFACTURER.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:01760 LIQUID BACTERIA
CAGE:NO601
CAGE:NO601
CAGE:0W7N2
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: TO 100%
Other REC Limits:NONE RECOMMENDED
Ingred Name:BACTERIA
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NONYLPHENOL POLYETHYLENE GLYCOL ETHER
CAS:127087-87-0
Fraction by Wt: 0-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:PERFUME OIL
Fraction by Wt: 0-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:STYRENE ACRYLATE RESIN
CAS:25085-34-1
Fraction by Wt: 0-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:BICYCLIC OXAZOLIDINES SOLUTION (HEMIACETALS)
CAS:56709-13-8
Fraction by Wt: 0-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NONYLPHENOL POLYETHOXATE
CAS:9016-45-9
RTECS #:MD0900000
Fraction by Wt: 0-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:PROPYLENE GLYCOL
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: 0-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NONIONIC SURFACTANT
Fraction by Wt: 0-5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT GIVEN FOR PRODUCT AS A WHOLE
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN CONTACT MAY CAUSE IRRITATION. MAY
CAUSE DERMAL SENSITIVITY. MAY INFECT OPEN WOUNDS. EYE CONTACT MAY
CAUSE IRRITATION. LIQUID OR MISTS MAY INFECT EYES. INGESTION MAY BE
IRRITATING TO GASTROINTESTI NAL SYSTEM, MOUTH, THROAT AND
ESOPHAGUS. VOMITING AND DIARRHEA EXPECTED WITH LARGE DOSES.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:SKIN IRRITATION, DERMAL SENSITIVITY, INFECTION,
EYE IRRITATION, GI TRACT IRRITATION, MOUTH/THROAT/ESOPHAGUS
IRRITATION, VOMITING, DIARRHEA.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN: REMOVE CONTAMINATED CLOTHING. WASH AFFECTED AREA WITH
SOAP AND WATER. SEEK MEDICAL ATTENTION IF IRRITATION PERSISTS.
EYES: FLUSH EYES WITH LARGE QUANTITIES OF WATER. SEEK MEDICAL
ATTENTION. INGE STION: DRINK TWO GLASSES OF WATER. SEEKMEDICAL
ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:NONFLAMMABLE. USE EXTINGUISHING MEDIA SUITABLE FOR
SURROUNDING FIRE.
Fire Fighting Procedures:NONFLAMMABLE. USE STANDARD FIREFIGHTING
PROCEDURES FOR SURROUNDING MATERIALS IN THE FIRE.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:MOP UP OR OTHERWISE ABSORB AND HOLD FOR
DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN. KEEP
CONTAINER CLOSED DURING STORAGE. FOR INDUSTRIAL AND INSTITUTIONAL
USE ONLY.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL CONDITIONS
Ventilation:LOCAL EXHAUST AND MECHANICAL (GENERAL) VENTILATION AS
REQUIRED TO MAINTAIN EXPOSURE LEVELS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:V7
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:20
Vapor Density:> 1
Spec Gravity:1.0
pH:7-8
Evaporation Rate & Reference:< 1 (WATER=1)
Solubility in Water:DISPERSES
Appearance and Odor:THIN MILKY LIQUID WITH PLEASANT ODOR
Percent Volatiles by Volume:80+%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PE-850 INDUSTRIAL ENAMEL COLORS
CAGE:29431
CAGE:29431
============= Composition/Information on Ingredients =============
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; PETROLEUM DISTILLATE,
HYDROTREATED
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 16-23%
OSHA PEL:1800 PPM
ACGIH TLV:350 MG/CUM
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 1-7.7%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOL ORGANIC CMPD: 317-517 G/L
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION, BURNING SENSATION, &
TEARING. SKIN: IRRITATION, DRYING, DERMATITIS, & CRACKING.
INHALATION: HEADACHE, DIZZINESS, DROWSINESS, NAUSEA, &
UNCONSCIOUSNESS. INGESTION: GASTROINTESTINAL TR ACT/DIGESTIVE TRACT
IRRITATION, NAUSEA,DIARRHEA, SEIZURES, COMA, VOMITING,
CARDIOPULMONARY ARREST, & DEATH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION, BURNING SENSATION, & TEARING.
SKIN: IRRITATION, DRYING, DERMATITIS, & CRACKING. INHALATION:
HEADACHE, DIZZINESS, DROWSINESS, NAUSEA, & UNCONSCIOUSNESS.
INGESTION: GASTROINTESTINAL/DI GESTIVE TRACT IRRITATION, NAUSEA,
VOMITING, DIARRHEA, SEIZURES, COMA, CARDIOPULMONARY ARREST, &
DEATH.
Medical Cond Aggravated by Exposure:DERMATITIS
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER.
INHALATION: REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT
ADMINSTER OXYGEN. INGESTION: ADMINISTER TWO GLASSES OF WATER IF
VICTIM IS ALERT. IF MORE THAN ONE SWALLOW WAS INGESTED, INDUCE
VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:108F
Lower Limits:1%
Extinguishing Media:FOAM, CO2, OR DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:VAPORS MAY FORM EXPOSIVE MIXTURES W/AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. ABSORB W/SAND.
FLUSH HEAVILY W/WATER. KEEP MATERIAL OUT OF SEWERS OR STREAMS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS COOL, DRY, & AWAY FROM
IGNITION SOURCES. CHECK ALL CONTAINERS FOR LEAKS. ATTACH GROUNDING
CABLE.
Other Precautions:AVOID BREATHING & PERSONAL CONTACT. DON'T TAKE
INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE MSHA/NIOSH APPROVED VAPOR RESPIRATOR.
Ventilation:LOCAL & MECHANICAL EXHAUST TO KEEP <TLV.
Other Protective Equipment:EYEWASH STATION, & EMERGENCY SHOWER
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
BOILING RANGE: 318-415F.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:SEE SUPP.
Vapor Pres:0.60-3.23
Vapor Density:4.2
Spec Gravity:0.976-1.441
Evaporation Rate & Reference:(BU AC = 1): <1
Solubility in Water:<0.1%
Appearance and Odor:CLEAR OR COLORED PASTE
Percent Volatiles by Volume:33-44
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS, STRONG BASES, & SELECTED AMINES
Stability Condition to Avoid:EXTREME COLD, HEAT, & ELEVATED
TEMPERATURES
Hazardous Decomposition Products:CO, CO2, & ANTIMONY
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF BY INCINERATION ACCORDING TO LOCAL,
STATE, & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:6604120 J5-RD1
Preparer's Name:S HEALY
CAGE:FO645
CAGE:FO645
CAGE:6Z677
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM AZIDE, AZIDE *96-4*
CAS:26628-22-8
RTECS #:VY8050000
Other REC Limits:0.1 PPM
ACGIH TLV:C 0.29 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NASAL IRRITATION. SKIN:
IRRITATION, ABSORPTION, ALLERGIC REACTION. EYES: IRRITATIONS,
CONJUNCTIVITIS. INGESTION: BRONCHIAL IRRITATION, RESPIRATORY
IRRITATION, RESPIRATORY FAILURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, FAINTNESS,
NAUSEA, LOW BLOOD PRESSURE, BLURRED VISION, SHORTNESS OF BREATH,
COLLAPSE, BRONCHITIS, PALPITATION, WEAKNESS & UNSTEADINESS, COMA,
CONVULSIONS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE CPR.
IF BREATHING IS DIFFICULT GIVE OXYGEN. SKIN: WASH OFF THOROUGHLY
FOR 15 MINS. EYES: RINSE THOROUGHLY W/WATER & GIVE PLENTY OF WATER
TO DRIN K. INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICALS SUCH AS AN SODIUM CARBONATE/SAND.
Fire Fighting Procedures:BURNING SODIUM AZIDE WILL EXPLODE IF WATER IS
USED AS AN EXTINGUISHING MEDIA. SCBA MUST BE WORN.
Unusual Fire/Explosion Hazard:MAY EXPLODE & RELEASE TOXIC FUMES UPON
HEATING. DON'T ALLOW TO CONTACT METALS AT HIGH TEMPS.
(SUPP)
================== Accidental Release Measures ==================
Spill Release Procedures:DILUTE W/RUNNING WATER BEFORE DISCHARGE.
DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM METALS & ACIDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Ventilation:GENERAL/LOCAL EXHAUST TO MEET TLV REQUIREMENTS
Other Protective Equipment:ADEQUATE LABORATORY ATTIRE
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
UNUSUAL FIRE CONT'D: FORMS HIGHLY SENSITIVE EXPLOSIVE COMPOUNDS W/HEAVY
METALS SUCH AS LEAD, SILVER & COPPER. WHEN HEATED TO 662F IT
DECOMPOSES EXOTHERMICALLY, BURNING W/A VERY HOT FLAME & PRODUCING N
ITROGEN & MOLTEN SODIUM.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:527F
Spec Gravity:1.85
Solubility in Water:40.16
Appearance and Odor:WHITE-COLORLESS CRYSTALS/POWDER, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
METALS, ACIDS, ACID CHLORIDES & STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT
Hazardous Decomposition Products:NITROGEN OXIDES, HYDRAZOIC ACID
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:T-20G TRACTOR & IMPLEMENT GRAY PRIMER
CAGE:TRUTE
CAGE:TRUTE
============= Composition/Information on Ingredients =============
Ingred Name:GROG; CALCIUM-BARIUM PHOSPHOSILICATE
*91-4*
CAS:66402-68-4
Fraction by Wt: 9-14%
OSHA PEL:15 MG/CUM
ACGIH TLV:20 MG/CUM
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM, MAGNESIUM SILICATE
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 20-25%
OSHA PEL:20 MPPCF
ACGIH TLV:2 MG/CUM (RESP DUST)
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; PETROLEUM DISTILLATE,
HYDROTREATED
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 22-27%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:VOL ORGANIC CMPD: <420 GM/L
RTECS #:9999999VO
Ingred Name:WEIGHT PER GALLON IN POUNDS: 10.8
RTECS #:9999999WG
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: HEADAHCE, DIZZINESS, &
NAUSEA. EYES: IRRITATION. SKIN: DRYNESS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: HEADACHE, DIZZINESS, & NAUSEA.
EYES: IRRITATION. SKIN: DRYNESS.
======================= First Aid Measures =======================
First Aid:EYES: WASH W/WATER. SKIN: WASH W/WARM WATER & SOAP.
INHALATION: REMOVE TO FRESH AIR. APPLY ARTIFICIAL RESPIRATION.
INGESTION: DON'T INDUCE VOMITING. KEEP WARM & QUIET. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:105F
Lower Limits:0.9%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. IF WATER SPRAY
IS USED, FOG NOZZLES ARE PERFERABLE. TREAT AS A VOLATILE LIQUID
FIRE.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. COMBUSTIBLE LIQUID.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. CONTAIN SPILL,
ABSORB LIQUID W/CALY, SAND, OR FLOOR ABSORBENT. PREVENT RUN-OFF TO
SEWERS, STREAMS, OR OTHER BODIES OF WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTAINERS SHOULD BE GROUNDED WHEN
POURING. KEEP AWAY FROM HEAT, SPARKS, & OPEN FLAMES. AVOID FREE
FALL OF MORE THAN 2-3 INCHES WHEN POURING.
Other Precautions:DON'T TAKE INTERNALLY. AVOID CONTACT W/SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED AIR-SUPPLIED RESPIRATOR
WHEN >TLV. USE APPROVED MECHANICAL FILTER TO REMOVE SOLID AIRBORNE
PARTICLES OF OVERSPRAY DURING APPLICATION.
Ventilation:SUFFICIENT MECHANICAL (GENERAL/LOCAL) TO KEEP <TLV.
Other Protective Equipment:IMPERVIOUS CLOTHING & BOOTS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS BEFORE EATING, SMOKING, OR USING BATHROOM.
Supplemental Safety and Health
BOILING RANGE: 300-380F.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:SEE SUPP.
Vapor Density:<AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:49%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTAMINATED ABSORBENT MAY BE DEPOSITED IN A
LANDFILL IN ACCORDANCE W/LOCAL, STATE, & FEDERAL REGULATIONS.
COMBUSTIBLE LIQUID.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:UNOPETTE BRAND TEST RETICULOCYTE STAIN KIT
CAGE:06531
CAGE:06531
============= Composition/Information on Ingredients =============
Ingred Name:METHYLENE BLUE DYE
CAS:61-73-4
RTECS #:SO5600000
= Wt:.5
Ingred Name:POTASSIUM OXALATE
CAS:6487-48-5
= Wt:1.6
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
Effects of Overexposure:ACUTE: SKIN & EYES: MAY CAUSE IRRITATION.
INHALATION: MAY CAUSE IRRITATION TO NOSE AND THROAT. INGESTION:
MAY CAUSE SEVERE POISONING OR DEATH. LARGE DOSES CAUSES A
SHOCK-LIKE STATE, CONVULSIONS, CO MA, OR DEATH. REPEATED EXPOSURE
EFFECTS: SKIN: MAY CAUSE DISCOLORATION OF FINGERS AND NAILS, AND
POSSIBLE ULCERS OR GANGRENE. INHALATION: NONE IDENTIFIED.
INGESTION: MAY CAUSE DEATH.
Medical Cond Aggravated by Exposure:NONE IDENTIFIED.
======================= First Aid Measures =======================
First Aid:SKIN: WASH WITH WATER FOR AT LEAST 15 MINUTES. IF IRRITATION
PERSISTS, SEEK MEDICAL ATTENTION. EYES: FLUSH WITH WATER FOR AT
LEAST 20 MINUTES. IF IRRITATION PERSISTS, SEEK MEDICAL ATTENTION.
INHAL ATION: REMOVE VICTIM TO FRESH AIR. INGESTION: DO NOT INDUCE
VOMITING. HAVE VICTIM DRINK 12 OZ. OF WATER TO DILUTE. SEEK
MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR THE
SURROUNDING TYPE OF FIRE.
Fire Fighting Procedures:NONE IDENTIFIED.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID OVEREXPOSURE. WEAR APPROPRIATE
PROTECTIVE CLOTHING. CONTAIN WITH ABSORBENT MATERIAL WHICH WILL NOT
REACT WITH MATERIAL. PLACE INTO SUITABLE, COVERED, LABELED
CONTAINER. FLUSH AREA WITH WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
AVOID CREATING DUST. STORE IN A COOL, DRY, WELL-VENTILATED AREA,
OUT OF DIRECT SUNLIGHT. STORE IN A SUITABLE, LABELED CONTAINER.
Other Precautions:LABEL: POISON DANGER. CAUSES BURNS. HARMFUL IF
INHALED. MAY BE FATAL IF SWALLOWED. DO NOT GET IN EYES, ON SKIN, OR
ON CLOTHING. AVOID BREATHING DUST. KEEP IN TIGHTLY CLOSED
CONTAINER. USE WITH ADEQUAT E VENTILATION. WASH THOROUGHLY AFTER
HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIFIC GUIDELINES ARE DETERMINED.
Ventilation:USE LOCAL EXHAUST VENTILATION TO CONTROL DUST LEVELS.
Other Protective Equipment:IMPERVIOUS COVERALLS AND LONG SLEEVES, EYE
BATH, SAFETY SHOWER, APRONS.
Supplemental Safety and Health
REORDER NUMBER: 005821. NFPA RATINGS:
FIRE=0;HEALTH=3;REACTIVITY=1;SPECIFIC HAZARD=3. HMIS RATINGS:
HEALTH=3;FLAMMABILITY=0;REACTIVITY=1.
================== Physical/Chemical Properties ==================
HCC:T4
Solubility in Water:MODERATELY SOLUBLE
Appearance and Odor:ODORLESS CRYSTALS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY REACT VIOLENTLY WITH STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:NONE IDENTIFIED.
=================== Toxicological Information===================
Toxicological Information:INHALATION TOXICITY: MAY CAUSE IRRITATION TO
NOSE AND THROAT. INGESTION TOXICITY: MAY CAUSE COMA OR POSSIBLY
DEATH.
===================== Ecological Information =====================
Ecological:NO DATA IS AVAILABLE ON THE ADVERSE EFFECTS OF THIS MATERIAL
ON THE ENVIRONMENT. NEITHER COD NOR BOD DATA ARE AVAILABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE DONE IN ACCORDANCE WITH
LOCAL, STATE, AND FEDERAL LAWS AND REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:PLEASE NOTE: THE INFORMATION CONTAINED IN THIS
SECTION APPLIES TO THE TRANSPORT OF FULL CASE CARTONS ONLY.
D.O.T.: PROPER SHIPPING NAME: TOXIC SOLIDS,ORGANIC N.O.S. (CONTAINS
POTASSIUM OXALATE); HAZA RD CLASS/I.D. NO./PACKING GROUP: 6.1,
UN2811, LTD.QTY., PG III; LABEL: NONE REQUIRED I.M.O.: LABEL:
TOXIC I.C.A.O./I.A.T.A.: LABEL: EXCEPTED QUANTITIES
===================== Regulatory Information =====================
SARA Title III Information:NONE
Federal Regulatory Information:REPORTABLE QUANTITY (RQ) UNDER EPA
CERCLA REGUALTIONS: NONE TSCA INVENTORY: YES.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HEY'DI POWDER X
CAGE:FO729
CAGE:1Z185
CAGE:FO729
============= Composition/Information on Ingredients =============
Ingred Name:PORTLAND CEMENT
CAS:65997-15-1
RTECS #:VV8770000
Other REC Limits:50 MPPCF (MSHA)
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYE/INHALATION/INGESTION:
IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN/EYE/INHALATION/INGESTION: IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: WASH W/WATER. INHALATION/INGESTION: OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:MATERIAL DOES NOT BURN.
================== Accidental Release Measures ==================
Spill Release Procedures:NORMAL CLEAN UP.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED WHEN WORKING W/PRODUCT IN MORTAR
STATE.
Other Protective Equipment:AS REQUIRED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:3.1
Solubility in Water:INSOLUBLE
Appearance and Odor:GRAY POWDER W/NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ULTRACOAT, TC GLOSS GREEN, BASE COMP A
Kit Part:Y
Preparer's Name:CHARLES L. GRUBBS
CAGE:98502
CAGE:98502
============= Composition/Information on Ingredients =============
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 5-20%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CYCLOHEXANONE (SARA III)
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: 10-25%
Other REC Limits:NONE SPECIFIED
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ISOAMYL KETONE
CAS:110-12-3
RTECS #:MP3850000
Fraction by Wt: < 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9293
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 15-30%
Other REC Limits:NONE SPECIFIED
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: < 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF NASAL, RESPIRATORY,
SKIN, EYES, THROAT & GASTROINTESTINAL TRACT; ALSO DERMATITIS,
CHEMICAL PNEUMONITIS, DEPRESSANT FOR CENTRAL NERVOUS SYSTEM, DAMAGE
TO LIVER, KIDNEYS, & LUNGS. CAN BE M ODERATELY TOXIC IF SWALLOWED.
OVEREXPOSURE CAN CAUSE LIVER ABNORMALITIES. CAN BE HARMFUL OR
FATAL.
Explanation of Carcinogenicity:CRYSTALLINE SILICA IS LISTED BY IARC AS
A PROBABLE HUMAN CARCINOGEN.
Effects of Overexposure:IRRITATION, DIZZINESS, WEAKNESS, FATIGUE,
NAUSEA, VOMITING, HEADACHES, ASPHYXIATION, DIARRHEA, SKIN & EYE
BURNS, COUGHING.
Medical Cond Aggravated by Exposure:REPORTS HAVE ASSOCIATED REPEATED
AND PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN AND NERVOUS SYSTEM DAMAGE.
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE TO FRESH AIR. GIVE CPR IF NECESSARY. SKIN
CONTACT: WASH WITH SOAP & WATER. EYE CONTACT: FLUSH WITH WATER FOR
AT LEAST 15 MINUTES, CONSULT PHYSICIAN. INGESTION: DRINK ONE OR TWO
GLASSE S OF WATER TO DILUTE. DO NOT INDUCE VOMITING. CONSULT
PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY. TREAT
SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:40F/4C
Lower Limits:1.1
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICALS
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE, WATER SHOULD BE USED
TO COOL CONTAINERS EXPOSED TO FIRE. FIRE FIGHTING PERSONNEL SHOULD
WEAR SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:DECOMP PRODUCTS MAY CAUSE HEALTH HAZ.
SYMPTOMS MAY NOT BE IMMED SEEN. OBTAIN MEDICAL ATTENTION. KEEP
CONTAINERS CLOSED & AWAY FROM HEAT/ELEC/FLAME; MAY EXPLODE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
BREATHING VAPORS. VENTILATE AREA. REMOVE WITH INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE CONTAINERS OUT OF SUN & AWAY
FROM HEAT/SPARKS/FLAMES. CLOSE CONTAINERS AFTER EACH USE. CONSULT
NFPA CODE FOR ADDITIONAL STORAGE REQUIREMENTS.
Other Precautions:USE APPROVED BONDING & GROUNDING PROCEDURES. OBSERVE
LABEL PRECAUTIONS. KEEP CLOSURES TIGHT & CONTAINER UPRIGHT TO
PREVENT LEAKS. NEVER USE PRESSURE TO EMPTY - DRUM IS NOT A PRESSURE
VESSEL. DO NOT WE LD OR FLAME CUT ON EMPTY DRUM.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ADEQUATE VENTILATION IS REQUIRED. USE NIOSH/MSHA
APPROVED RESPIRATOR DEVICE. IN CONFINED AREAS USE NIOSH/MSHA
APPROVED AIRLINE RESPIRATOR OR HOOD. SEE SAFETY EQUIPMENT SUPPLIER
FOR EVALUATION & RECOMM ENDATION.
Ventilation:PROVIDE SUFFICIENT VENTILATION TO CONTROL CONCENTRATE OF
HAZARDOUS INGREDIENTS.**
Other Protective Equipment:USE CHEMICAL RESISTANT APRON
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING OR USING
WASHROOM. USE EYE BATH, SHOWER, CHEMICAL RESISTANT APRON, BOOTS,
AND SHOES.
Supplemental Safety and Health
** FOR BAKING FINISHES, EXHAUST VAPORS EMITTED ON HEATING. REMOVE
DECOMPOSITION PRODUCTS FORMED DURING WELDING OR FLAME CUTTING OF
SURFACES COATED WITH THIS PRODUCT. DO NOT USE THIS PRODUCT UNTIL
THE MANUFACTURER'S SAFETY PRECAUTIONS HAVE BEEN READ AND
UNDERSTOOD.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:230 TO 312F
Vapor Density:> THAN AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:33.6
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
SMOKE, OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS. DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE, AND LOCAL POLLUTION CONTROL REQUIREMENTS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LBP-20
CAGE:1BA63
CAGE:08YZ7
CAGE:1BA63
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE ACRYL COPOLYMER
Fraction by Wt: 55-60%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:IRON OXIDE
CAS:1317-61-9
Fraction by Wt: 35-40%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3 (FE)
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT)3200 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MINIMAL RESPIRATORY TRACT IRRITATION
MAY OCCUR AS WITH EXPOSURE TO LARGE AMOUNTS OF ANY NON-TOXIC DUST.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM EXPOSURE. EYE: NO SPEC HAZ IS KNOWN.
HOWEVER, ANY MATERIAL THAT CONTACTS EYE MAY BE IRRITATING. FLUSH
WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. SKIN: WASH WITH SOAP
AND WATER. I NGEST: CALL MD IMMED .
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, DRY CHEMICAL, CO2.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MATL, LIKE MOST ORG MATLS IN POWDER FORM
IS CAPABLE OF CREATING A DUST EXPLO. REFER TO NFPA PAMPHLET NO.
654, "STD FOR PREVENTION OF FIRE & DUST EXPLO (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP MATERIAL ONTO PAPER AND PLACE IN FIBER
CARTON.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN. KEEP
FROM CONTACT WITH OXIDIZNG MATERIALS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT.
Other Protective Equipment:NONE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ: IN CHEMICAL, DYE, PHARMACEUTICAL AND PLASTICS INDUSTRIES",
IF THIS MATERIAL IS TO BE REDUCED/COLLECTED AS A POWDER.
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Pres:NEGLIGIBLE
Spec Gravity:1.4(H2O=1)
Evaporation Rate & Reference:NEGLIG(N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:FINE POWDER, SLIGHT PLASTIC ODOR
Percent Volatiles by Volume:NEGLIG
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:AS WITH ANY OTHER ORGANIC MATERIAL,
COMBUSTION WILL PRODUCE CARBON DIOXIDE AND PROBABLY CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:NO SPECIAL DISPOSAL TECHNIQUE REQUIRED. ENSURE
COMPLIANCE WITH FEDERAL, STATE AND/OR LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AMMONIUM HYDROXIDE,A 669-212
CAGE:1B464
CAGE:22527
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIUM HYDROXIDE (CERCLA)
CAS:1336-21-6
RTECS #:BQ9625000
Fraction by Wt: 28 - 30%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) 350 MG/KG (RTECS, NH3)
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY
& GI TRACTS. ACUTE- CORROSIVE. MAY CAUSE SEVERE EYE BURNS & DAMAGE.
CONTACT WITH SKIN MAY CAUSE SEVERE IRRITATION & BURNS. INHALATION
MAY CAUSE SEVERE IRRITATION & BURNS OF UPPER RESPIRATORY TRACT,
COMA. INGESTION MAY BE FATAL. CAUSES BURNS. CHRONIC- MAY CAUSE
CORNEAL DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SEVERE IRRITATION, SEVERE BURNS, TEARING,
SEVERE COUGHING, DESTRUCTION OF TISSUE ON ANY EXPOSED PART OF THE
BODY, CHEST PAIN, NAUSEA, VOMITING, DIFFICULT BREATHING,
CONVULSIONS, DEEP ULCERS OF SKIN, B LINDNESS
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE DISORDERS, SKIN
DISORDERS OR IMPAIRED RESPIRATORY FUNCTION MAY BE MORE SUSCEPTIBLE
TO THE EFFECTS OF THIS MATERIAL.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IMMEDIATELY. EYES/SKIN:IMMEDIATELY
FLUSH WITH WATER FOR 15 MINUTES. HOLD EYELIDS OPEN. INHALED:MOVE TO
FRESH AIR. PROVIDE OXYGEN/CPR IF NEEDED. ORAL:IF CONSCIOUS, DRINK
2-4 CUPFU LS OF MILK/WATER. DO NOT INDUCE VOMITING. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NOT RELEVANT
Upper Limits:NOT RELEVANT
Extinguishing Media:WATER SPRAY. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS WITH FULL
FACEPIECE OPERATED IN POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:AMMONIUM HYDROXIDE IS NON-COMBUSTIBLE AND
NON-EXPLOSIVE, BUT AMMONIA VAPORS RELEASED FROM SOLUTION CAN FORM
EXPLOSIVE MIXTURE WITH AIR IN CONFINED AREAS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. VENTILATE AREA.
RECOVER IF POSSIBLE. ABSORB SPILL WITH INERT MATERIAL SUCH AS DRY
SAND. PLACE INTO A CHEMICAL WASTE CONTAINER. NEUTRALIZE WITH
VINEGAR OR ACETIC ACID.
Neutralizing Agent:DILUTE ACETIC ACID
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, WELL-VENTILATED AREA
AWAY FROM DIRECT SUNLIGHT & INCOMPATIBLE MATERIALS. STORE IN A
CORROSIVE PROOF AREA.
Other Precautions:AVOID CONTACT WITH EITHER LIQUID OR VAPORS.
CONTAINERS SHOULD BE KEPT WELL SEALED WHEN NOT IN USE. MATERIAL MAY
ATTACK ZN, CU, HG, SN AND THEIR ALLOYS. KEEP OUT OF REACH OF
CHILDREN. FOR LABORATORY US E ONLY. DO NOT BREATHE VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WORK IN FUME HOOD OR WEAR A NIOSH-APPROVED
RESPIRATOR WITH AMMONIA CANISTER, IF NEEDED.
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP FUME OR
VAPOR LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:USE RUBBER SPLASH APRON. SAFETY SHOWER AND
EYEWASH FOUNTAIN SHOULD BE LOCATED NEARBY.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH AFTER HANDLING AND BEFORE EATING OR
DRINKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:B1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:82.4F,28.0C
Melt/Freeze Pt:M.P/F.P Text:-106.6F;NH3
Vapor Pres:115 @ 68F
Vapor Density:1.2
Spec Gravity:0.9
pH:13.6
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID WITH STRONG SUFFOCATING AMMONIA
ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, ACROLEIN, ACRYLIC ACID, DIMETHYL SULFATE, FLUORINE,
IODINE, PROPYLENE OXIDE, HALOGENS, HEAVY METAL CMPDS
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:AMMONIA GAS AND NITROGEN OXIDES MAY BE
FORMED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. REUSING OR RECYCLING IS RECOMMENDED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:3-4347 PANTONE RUBBER BASE INK
Preparer's Name:KENNETH W. PINTER
CAGE:17638
CAGE:17638
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM HYDROCARBON (SEVERLY HYDROTREATED)
CAS:64742-46-7
Fraction by Wt: 7-12%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:PROLONGED OR REPEATED SKIN CONTACT MAY
LEAD TO IRRITATION AND DERMATITIS.
Explanation of Carcinogenicity:CONTAINS NO MATERIALS THAT ARE
CONSIDERED TO BE CARCINOGENS BY NTP,IARC OR OSHA.
Effects of Overexposure:ORAL INGESTION MAY CAUSE IRRITATION OR GASTRIC
DISTURBANCE. MAY BE SLIGHTLY IRRITATING UPON DIRECT EYE CONTACT.
MAY CAUSE IRRITATION AND DERMATITIS-DERMATITIS CHARACTERIZED BY
DRYNESS,CHAPPING AND RED DENING. OIL MISTS MAY CAUSE IRRITATION OF
THE THROAT AND LUNGS.
======================= First Aid Measures =======================
First Aid:INGESTION-DO NOT INDUCE VOMITING. CONSULT A PHYSICIAN.
EYES-RINSE THOROUGHLY WITH WATER FOR 15 MIN. IF IRRITATION
PERSISTS,CONSULT A PHYSICIAN. SKIN-WASH WITH SOAP AND WATER. IF
IRRITATION PERSISTS,CO NSULT A PHYSICIAN. INHALATION-REMOVE TOFRESH
AIR. APPLY OXYGEN IF NEEDED. CONSULT A PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM,CO2,DRY CHEMICAL,WATER FOG.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE,BUT CAN BE USED TO
COOL CONTAINERS EXPOSED TO HEAT AND FLAME.
Unusual Fire/Explosion Hazard:DENSE SMOKE MAY BE GENERATED WHILE
BURNING.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP AND DISPOSE OF WITH SOLID WASTE. IF
SOLVENT WETTED WIPES WERE USED,DISPOSE OF IN APPROVED CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE. KEEP CONTAINERS AWAY FROM EXCESSIVE HEAT,SPARKS AND OPEN
FLAME.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED.
Ventilation:MECHANICAL VENTILATION ACCEPTABLE.
CLEANING PRESSES.
Work Hygienic Practices:WASH HANDS AND FACE WITH SOAP AND WATER BEFORE
EATING OR SMOKING.
Supplemental Safety and Health
FOR INDUSTRIAL USE ONLY.
================== Physical/Chemical Properties ==================
Vapor Density:>1
Spec Gravity:1.02-1.11
Solubility in Water:INSOLUBLE
Appearance and Odor:INK VARNISH ODOR,PASTE.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CO,CO2 AND SMOKE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE WITH LOCAL,STATE AND FEDERAL
REGULATIONS FOR NON-FLAMMABLE OILY WASTE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TM-2001 WHITE GREASE
CAGE:2F853
CAGE:2F853
CAGE:70842
CAGE:0NBN5
============= Composition/Information on Ingredients =============
Ingred Name:HEXANE (N-HEXANE) (CERCLA)
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: 11%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM
ACGIH TLV:50 PPM; 9596
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:MINERAL SPIRITS
CAS:64742-88-7
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:PROPANE PLUS INGRED 4
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 12%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9596
Ingred Name:ISOBUTANE PLUS INGRED 3
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: SEE #3%
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 63%
Other REC Limits:NONE RECOMMENDED
Ingred Name:GREASE, MIXTURE
Fraction by Wt: 9%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE DIZZINESS OR NARCOSIS IN
HIGH VAPOR CONCENTRATIONS.WILL CAUSE DEFATTING OF SKIN.EFFECTS ARE
REVERSIBLE.LONG TERM EXPO (EARS)VAPOR MAY CAUSE LUNG,LIVER OR
KIDNEY DMG.THE SOLVENTS LISTED HAVE BEEN REPORTED TO AFFECTS
CENTRAL NERVOUS SYSTEM.
Explanation of Carcinogenicity:PER MSDS:CARCINOGEN:PRESENTLY NOT ON ANY
LIST.
Effects of Overexposure:INHALATION-DIFFICULTY IN
BREATHING.SKIN-REDNESS.INGESTION-VOMITING.
Medical Cond Aggravated by Exposure:HEART DISEASE; RESPIRTORY
DISORDERS.
======================= First Aid Measures =======================
First Aid:GIVE OXYGEN.DO NOT INDUCE VOMITING.GASTRIC LAVAGE.WASH EYES
AND SKIN WITH WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-40F,-40C
Autoignition Temp:Autoignition Temp Text:NP
Lower Limits:1.8
Upper Limits:12.0
Extinguishing Media:USE WATER FOG, DRY CHEMICAL OR CARBON DIOXIDE.
Fire Fighting Procedures:AEROSOL CANS MAY RUPTURE WHEN HEATED.
Unusual Fire/Explosion Hazard:HEATED CANS MAY BURST.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT SWEEPING COMPOUND TO SOAK UP
MATERIAL.PUT INTO CONTAINER.DISPOSE AS HAZARDOUS WASTE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT,SPARKS,OR OPEN
FLAME.STORE AT TEMPERATURE BELOW 120F.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELF-CONTAINED BREATHING APPARATUS IF ABOVE TLV
LIMIT EXCEEDING.
Ventilation:LOCAL EXHAUST:YES. MECHANICAL(GEN):NONE
Other Protective Equipment:LONG SLEEVE AND LONG PANTS.
Work Hygienic Practices:DO NOT SMOKE WHIEL USING.WASH HANDS AFTER USE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:-40F,-40C
Melt/Freeze Pt:M.P/F.P Text:NA, LIQ
Decomp Temp:Decomp Text:NP
Vapor Pres:60
Vapor Density:4.0
Spec Gravity:0.8
pH:NP
Viscosity:NP
Evaporation Rate & Reference:<1, BUTYL ACETATE=1
Solubility in Water:PARTIAL
Appearance and Odor:WHITE/SOLVENT ODOR
Percent Volatiles by Volume:NP
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
THE ABOVE SOLVENTS ARE INCOMPATIBLE W/STRONG OXIDIZERS.
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:IN FIRE WILL DECOMPOSE TO CARBON
DIOXIDE AND WATER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE AS HAZARDOUS WASTE IN ACCORDANCE WITH
EPA RCRA.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:LEAD NITRATE
Preparer's Name:ALEXANDER A PICCIRILLI
CAGE:EO227
CAGE:EO227
CAGE:63759
============= Composition/Information on Ingredients =============
Ingred Name:LEAD NITRATE (SARA 313)
CAS:10099-74-8
RTECS #:OG2100000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE 1910.1025
ACGIH TLV:0.15 MG(PB)/M3; 9495
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS 93 MG/KG (RTECS).
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, KIDNEY,
RESPIRATORY & GI TRACTS. ACUTE- POISON. EYE/SKIN:MAY CAUSE
IRRITATION. INHALE/INGESTION:MAY CAUSE WEAKNESS, FATIGUE, SLEEP
DISTURBANCES, HEADACHE, ACHING BONES & MUSCL ES, ABDOMINAL PAIN,
CONSTIPATION & DECREASED APPETITE. CHRONIC- ANEMIA, PALLOR,
CONVULSIONS, COMA, KIDNEY INJURY, DEATH.
Explanation of Carcinogenicity:LEAD NITRATE.
Effects of Overexposure:IRRITATION, WEAKNESS, FATIGUE, SLEEP
DISTURBANCES, HEADACHE, ACHING BONES & MUSCLES, ABDOMINAL PAIN,
CONSTIPATION, DECREASED APPETITE, ANEMIA, PALLOR, CONVULSIONS,
COMA, KIDNEY INJURY, POSSIBLY DEATH
======================= First Aid Measures =======================
First Aid:CALL A DOCTOR IF SYMPTOMS PERSIST. EYE:FLUSH WITH WATER FOR
15 MINUTES. HOLD EYELIDS OPEN. SEE PHYSICIAN. SKIN:FLUSH WITH
WATER, THEN WASH WITH SOAP & WATER. INHALED:REMOVE TO FRESH AIR.
PROVIDE CPR/O XYGEN IF NEEDED. ORAL:IF CONSCIOUS, DRINK WATER &
INDUCE VOMITING. CALL A PHYSICIAN/POISON CONTROL CENTER
IMMEDIATELY. NEVER GIVE FLUID OR INDUCE VOMITING IF PATIENT IS
UNCONSCIOUS OR HAS CONVULSIONS.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. FORMS TOXIC FUMES. SEE 1990
EMERGENCY RESPONSE GUIDEBOOK, GUIDE NO 42.
Unusual Fire/Explosion Hazard:OXIDIZER. INCREASES THE FLAMMABILITY OF
ANY COMBUSTIBLE SUBSTANCES.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SUITABLE PROTECTIVE CLOTHING. AVOID
MAKING DUST. SWEEP UP AND PLACE IN A SUITABLE CONTAINER FOR LATER
DISPOSAL. WASH SPILL SITE WELL WITH SOAP AND WATER AFTER PICK UP IS
COMPLETE.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, VENTILATED PLACE
AWAY FROM COMBUSTIBLE MATERIALS AND FIRE HAZARDS. KEEP CONTAINER
TIGHTLY CLOSED.
Other Precautions:POISON AND OXIDIZER. AVOID CREATING DUST. DO NOT GET
IN EYES, ON SKIN OR ON CLOTHING. AVOID INHALATION OF DUST OR FUME.
KEEP OUT OF REACH OF CHILDREN. OBEY HAZARD WARNING LABEL. FOR
LABORATORY USE ONL Y. NOT FOR DRUG, FOOD OR HOUSEHOLD USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED IN NORMAL LABORATORY
HANDLING. IF DUSTY CONDITIONS PREVAIL, WORK IN A FUME HOOD OR WEAR
A NIOSH-APPROVED DUST RESPIRATOR OR DUST MASK. IN EMERGENCY, WEAR
NIOSH-APPROVED SELF-CONT AINED BREATHING APPARATUS.
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO MEET TLV
REQUIREMENTS.
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER, PROTECTIVE
CLOTHING AND/OR UNIFORM
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:D2
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:DECOMPOSES
Melt/Freeze Pt:M.P/F.P Text:DECOMPOSE
Decomp Temp:Decomp Text:878F,470C
Vapor Pres:NEGLIGIBLE
Vapor Density:11.45
Spec Gravity:4.53
Viscosity:NOT RELEVANT
Evaporation Rate & Reference:NOT RELEVANT
Solubility in Water:50% @ 68F (20C)
Appearance and Odor:WHITE OR COLORLESS TRANSLUCENT CRYSTALS - ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ORGANIC MATERIALS, REDUCING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:MAY FORM OXIDES OF NITROGEN, LEAD
FUME.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. MAY BE DISPOSED OF IN AN APPROVED CHEMICAL
LANDFILL OR CONTRACT WITH A LICENSED WASTE DISPOSAL SERVICE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:2497 ZEP MARINE EXCEED
CAGE:72674
CAGE:27674
CAGE:72674
============= Composition/Information on Ingredients =============
Ingred Name:NONYL PHENOXYPOLY (ETHYLENEOXY) ETHANOL
CAS:9016-45-9
Fraction by Wt: 10-20%
Ingred Name:KEROSENE
CAS:8008-20-6
RTECS #:OA5500000
Fraction by Wt: 10-20%
Other REC Limits:100 MG/CUM NIOSH
Ingred Name:SOLVENT NAPHTHA, HEAVY AROMATIC NAPHTHA
CAS:64742-94-5
RTECS #:WF3100000
Fraction by Wt: 60-70%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NOSE/THROAT IRRITATION,
HARMFUL, CENTRAL NERVOUS SYSTEM DEPRESSION, HEADACHE, NAUSEA,
VERTIGO, STUPOR & COMA. EYE: IRRITATION, TISSUE INFLAMMATION,
REDNESS, WATERING, & ITCHING. INGESTION: CHEMICAL PNEUMONIA
W/ASPIRATION OF VOMITUS INTO LUNGS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: MILD CNS DEPRESSION, HEADACHE, NAUSEA,
STUPOR, COMA DEFATTING, IRRITATION, INGESTION & DERMATITIS.
Medical Cond Aggravated by Exposure:RESPIRATORY DISORDERS OR SKIN
DISEASES
======================= First Aid Measures =======================
First Aid:SKIN: WASH THOROUGHLY W/SOAP OR A MILD DETERGENT. APPLY A
CREAM W/LANOLIN. EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15
MINS. INHALATION: MOVE EXPOSED PERSON TO FRESH AIR. INGESTION:
DON'T INDUCE VOM ITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:145F
Lower Limits:1.0%
Upper Limits:7.0%
Extinguishing Media:CO2, FOAM, DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED POSITIVE PRESSURE
BREATHING APPRATUS.
Unusual Fire/Explosion Hazard:FIRE EXPOSED DRUMS SHOULD BE COOLED
W/STREAM OF WATER. COMBUSTIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL FLAME, IGNITION & HIGH-HEAT
SOURCES. ABSORB SPILL ON INERT ABSORBENT MATERIAL. PICK UP & PLACE
RESIDUE IN A CLEAN, D.O.T. SPECIFICATION CONTAINER FOR DISPOSAL.
WASH AREA THOROUGHLY W/A D ETERGENT SOLUTION/RINSE WELL W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:COMBUSTIBLE. STORE & USE AWAY FROM
HEAT, SPARKS, OPEN FLAME, OR ANY SOURCE OF IGNITION. KEEP PRODUCT
AWAY FROM SKIN/EYES/FOOD PRODUCTS.
Other Precautions:KEEP OUT OF THE REACH OF CHILDREN. STORE TIGHTLY
CLOSED CONTAINER IN A DRY AREA AT TEMPS 40-120F. DON'T BREATHE
SPRAY MISTS OR VAPORS. AVOID USE OF CONTACT LENSES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION IS INADEQUATE, WEAR A PROPERLY
FITTING MSHA OR OSHA-APPROVED RESPIRATOR.
Ventilation:VENTILATION SHOULD BE EQUIVALENT TO OUTDOORS. USE EXHAUST
FANS & OPEN WINDOWS IN ENCLOSED SPACES
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING, SHOES & CLEAN
THOROUGHLY BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:355-550F
Vapor Pres:0.4
Vapor Density:5.0
Spec Gravity:0.95
Evaporation Rate & Reference:(BU AC = 1): <0.01
Solubility in Water:EMULSIFIES
Appearance and Odor:CLEAR, LIGHT STRAW-COLORED LIQUID W/MILD AROMATIC
ODOR.
Percent Volatiles by Volume:82%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, OPEN FLAME, SPARKS, ANY SOURCE OF
IGNITION.
Hazardous Decomposition Products:CO, CO, & OTHER UNIDENTIFIED ORGANIC
COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:LIQUID WASTES AREN'T PERMITTED IN LANDFILLS.
PRODUCT ISN'T CONSIDERED A HAZ. WASTE UNDER RCRA. UNUSABLE LIQUID
MAY BE ABSORBED ON AN INERT ABSORBENT, DRUMMED/TAKEN TO A
CHEMICAL/INDUSTRIAL LANDFILL. C ONSULT LOCAL/STATE/FEDERAL AGENCIES
FORDISPOSAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:142 8366, EKTACOLOR RA BLEACH FIX & REPLENISHER, PART B
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 60-64%
Other REC Limits:NONE RECOMMENDED
Ingred Name:FERRIC AMMONIUM ETHYLENEDIAMINETETRAACETIC ACID
CAS:21265-50-9
Fraction by Wt: 35-40%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIAMMONIUM ETHYLENEDIAMINE TETRAACETIC ACID
CAS:20824-56-0
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS UNKNOWN.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:LOW HAZARD FOR RECOMMENDED HANDLING.
MAY CAUSE TRANSIENT EYE IRRITATION. LOW INGESTION HAZARD.
Explanation of Carcinogenicity:IN ADDITION TO THE ABOVE, PRODUCT IS
NEGATIVE W/REGARD TO:ACGIH CANCER, CALIFORNIA CANCER & REPRODUCTIVE
EFFECTS.
Effects of Overexposure:EYE:TRANSIENT IRRITATION.
Medical Cond Aggravated by Exposure:MFR GAVE NO INFORMATION ON MSDS.
======================= First Aid Measures =======================
First Aid:INHALATION:IF SYMPTOMATIC,REMOVE TO FRESH AIR. IF SYMPTOMS
PERSIST, GET MEDICAL ATTENTION. EYES:FLUSH W/PLENTY OF WATER FOR 15
MIN. GET IMMEDIATE MEDICAL ATTENTION. SKIN:WASH W/SOAP & WATER. GET
MEDIC AL ATTENTION IF SYMPTOMS OCCUR. INGESTION:DRINK 1-2 GLASSES
OF WATER. SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL
FOAM
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH SPILLS TO SEWER WITH LARGE AMOUNT OF
WATER.
Neutralizing Agent:MFR GAVE NO INFORMATION ON MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED.
Other Precautions:USE ONLY W/ADEQUATE VENTILATION. WASH THOROUGHLY
AFTER HANDLING. KEEP FROM CONTACT W/OXIDIZING MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:USE GOOD GENERAL VENTILATION (10 CHANGES/HR). MATCH
VENTILATION RATES TO CONDITIONS.
Other Protective Equipment:EYE BATH, WASHING FACILITIES, SAFETY SHOWER.
PROTECTIVE CLOTHING APPROPRIATE FOR THE RISK OF EXPOSURE.
Work Hygienic Practices:EK: ? HMIS:USE GOOD INDUSTRIAL HYGIENE
PRACTICES. MINIMIZE PERSONAL CONTACT. WASH THOROUGHLY AFTER
HANDLING.
Supplemental Safety and Health
KAN 471213; PCD 5670; P-0007.230. ECOLOGICAL DATA:OXYGEN DEMAND =
MODERATE. GERMINATION & PLANT EFFECTS = LOW, WASTE TREATMENT
MICROBE EFFECT = LOW, BIOCONCENTRATION = LOW, ADVERSE EFFECTS AFTER
DILU TION & TREATMENT = NONE.
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NONE
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:18 MM
Vapor Density:0.6
Spec Gravity:1.22
pH:7.0
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID, DARK BROWN, SLIGHT AMMONIA ODOR
Percent Volatiles by Volume:60-65
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:MFR GAVE NO INFORMATION ON MSDS.
Hazardous Decomposition Products:AMMONIA
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE, OR LOCAL LAWS. FLUSH TO SEWER W/LARGE AMOUNTS
OF WATER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EZ-KARE SEMI-GLOSS ENAMEL EZ-8
CAGE:3D277
CAGE:3D277
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL
CAS:107-21-1
RTECS #:KW2975000
Minumum % Wt:2.
Maxumum % Wt:5.
ACGIH STEL:C127 MG/M3;C50 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:INHALATION: IRRITATING TO EYES, NOSE,
THROAT & MUCOUS MEMBRANES OF RESPIRTORY TRACT. SKIN:
PROLONGED/REPEATED CONTACT MAY CAUSE IRRITATION. EYES: MAY RESULT
IN IRRITATION.
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SKIN: REMOVE W/SOAP & WATER.
EYES: FLUSH IMMEDIATELY W/LARGE AMOUNTS OF WATER. INGESTION: GIVE
1-2 GLASSES OF WATER TO DILUTE. DON'T INDUCE VOMITING. OBTAIN
MEDICAL AT TENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:WATER MAY BE USED TO COOL CLOSED CONTAINERS TO
PREVENT PRESSURE BUILD UP & EXPLOSION.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE & CONTAIN LEAK W/INERT MATERIAL; SAND &
EARTH. TRANSFER THE LIQUID TO CONTAINERS FOR RECOVERY/DISPOSAL.
KEEP OUT OF SEWERS & OPEN BODIES OF WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING. AVOID PROLONGED
CONTACT W/SKIN.
Other Precautions:DON'T TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED IF GOOD VENTILATION IS MAINTAINED.
DURING SPRAY APPLICATION, USE AN APPROVED MECHANICAL FILTER
RESPIRATOR TO REMOVE AIRBORNE PARTICLES/OVERSPRAY.
Ventilation:SUFFICIENT VENTILATION SHOULD BE PROVIDED TO KEEP THE AIR
CONTAMINANT CONCENTRATION BELOW CURRENT APPLICABLE OSHA PEL/ACGIH:
TLV LIMITS.
Other Protective Equipment:EYEWASH FACILITY, PROTECTIVE CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE. WASH HANDS BEFORE EATING, SMOKING/USING THE WASHROOM.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:=100.C, 212.F
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:68
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:FREEZING
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:LIQUID MATERIAL & CONTAMINATED DIKING MATERIALS
SHOULD BE LANDFILLED/DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
======================= Other Information =======================
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS & SYNTHETIC RUBBER & STEEL COMPOSITION
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AWS 308MO
CAGE:0AES5
CAGE:0AES5
============= Composition/Information on Ingredients =============
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
OSHA PEL:5 MG/CUM
ACGIH TLV:10 MG/CUM
Ingred Name:CHROMIUM METAL, CHROMIUM, CHROME (SUSPECTED A1 HUMAN
CARCINOGEN BY IARC, NTP & ACGIH)
CAS:7440-47-3
RTECS #:GB4200000
OSHA PEL:1 MG/CUM (CEILING)
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:NICKEL (SOLUBLE) (SUSPECTED HUMAN CARCINOGEN BY NTP, IARC,
ACGIH) INTENDED CHANGE (IC)
CAS:7440-02-0
RTECS #:QR5950000
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/CUM
ACGIH TLV:0.05 MG/CUM IC
Ingred Name:MANGANESE, MN COMPOUNDS
CAS:7439-96-5
RTECS #:OO9275000
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:MOLYBDENUM (SOLUBLE COMPOUND), LEAD MOLYBDATE
CAS:7439-98-7
RTECS #:QA4680000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:YES
Health Hazards Acute and Chronic:EYES: IRRITATION, BURNS. SKIN: BURNS.
INHALATION: DIZZINESS, NAUSEA, NOSE/THROAT IRRITATION, TIGHTNESS IN
CHEST, FEVER. ELECTRICK SHOCK CAN KILL.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:INHALATION: SIDEROSIS (IRON DEPOSIT IN LUNGS).
MAY AFFECT PULMONARY FUNCTION.
======================= First Aid Measures =======================
First Aid:EMPLOY FIRST AID TECHNIQUES RECOMMENDED BY THE AMERICAN RED
CROSS. REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN ALL CASES
===================== Fire Fighting Measures =====================
Unusual Fire/Explosion Hazard:WELDING ARC & SPARKS CAN IGNITE
COMBUSTIBLES & FLAMMABLES.
======================Handling and Storage ======================
Handling and Storage Precautions:READ & UNDERSTAND THE MANUFACTURER'S
INSTRUCTIONS & THE PRECAUTIONARY LABEL ON THE PRODUCT.
Other Precautions:ONE RECOMMENDED WAY TO DETERMINE THE
COMPOSITION/QUANTITY OF FUMES/GASES TO WHICH WORKERS ARE EXPOSED IS
TO TAKE AN AIR SAMPLE FROM INSIDE THE WELDER'S HELMET IF WORN OR IN
THE WORKER'S BREATHING ZONE .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRABLE FUME RESPIRATORY OR AIR SUPPLIED
RESPIRATOR WHEN WELDING IN A CONFINED SPACE OR WHERE LOCAL EXHAUST
OR VENTILATION DOES NOT KEEP EXPOSURE BELOW THE RECOMMENDED
EXPOSURE LIMIT.
Ventilation:LOCAL EXHAUST AT THE ARC OR BOTH TO KEEP THE FUMES & GASES
FROM THE WORKER'S BREATHING ZONE & GENERAL AREA.
APRON, HATS, SHOULDER PROTECTION, AS WELL AS SUBSTANTIAL CLOTHING.
Work Hygienic Practices:TRAIN THE WELDER NOT TO TOUCH LIVE ELECTRICAL
PARTS & TO INSULATE HIMSELF FROM WORK & GROUND.
Supplemental Safety and Health
COMPOSITION & QUALITY OF WELDING FUMES & GASES ARE DEPENDENT UPON METAL
BEING WELDED, PROCESS, PROCEDURE & ELECTRODES USED. DECOMPOSITION
PRODUCT OF NORMAL OPERATION INCLUDE THOSE ORIGINATING FROM VOL
ATILIZATION, REACTION, OXIDATION OF MATERIALS IN INGREDIENTS, PLUS
THOSE FROM THE BASE METAL & COATING, ETC.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO, CO2. OZONE & NITROGEN OXIDES MAY
BE FORMED BY THE RADIATION FROM THE ARC, SHIELDING GASES
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT RESIDUE, DISPOSABLE CONTAINER OR
LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER, IN FULL COMPLIANCE
W/FEDERAL, STATE & LOCA L REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:211C-1, HEXANE
CAGE:IO526
CAGE:IO526
CAGE:58378
============= Composition/Information on Ingredients =============
Ingred Name:HEXANE (N-HEXANE)
CAS:110-54-3
RTECS #:MN9275000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM
ACGIH TLV:50 PPM; 9394
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS 2870 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF SWALLOWED, INHALED OR
ABSORBED THROUGH SKIN. VAPOR OR MIST IS IRRITATING TO THE EYS,
MUCOUS MEMBRANES AND UPPER RESPIRATORY TRACT. CAUSES SKIN
IRRITATION. MAY CAUSE NERVOUS SYSTEM DISTURBAN CES.
Explanation of Carcinogenicity:NOT CARCINOGENIC.
Effects of Overexposure:EXPOSURE CAN CAUSE: COUGHING, CHEST PAINS,
DIFFICULTY BREATHING AND EDEMA WHICH MAY BE FATAL. GASTROINTESTINAL
DISTURBANCES, NAUSEA, HEADACHE, AND VOMITING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:IN CASE OF CONTACT, IMMEDIATELY FLUSH EYES OR SKIN WITH
COPIOUS AMOUNTS OF WATER FOR AT LEAST 15 MINUTES WHILE REMOVING
CONTAMINATED CLOTHING/SHOES. IF INHALED, REMOVE TO FRESH AIR. IF
NOT BREATHING G IVE ARTIFICIAL RESPIRATION. IF BREATHINGIS
DIFFICULT, GIVE OXYGEN. IF SWALLOWED, WASH OUT MOUTH WITH WATER
PROVIDED PERSON IS CONSCIOUS. CALL A PHYSICIAN. WASH CONTAMINATED
CLOTHING BEFORE REUSE.
===================== Fire Fighting Measures =====================
Flash Point:=-23.3C, -10.F
Autoignition Temp:=250.C, 482.F
Lower Limits:1.2
Upper Limits:7.7
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER OR APPROPIATE
FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING TO PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:VAPOR MAY TRAVEL CONSIDERABLE DISTANCE TO
SOURCE OF IGNITION AND FLASHBACK. CONTAINER EXPLOSION MAY OCCUR
UNDER FIRE CONDITIONS. EXTREMELY FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. SHUT OFF SOURCE OF IGNITION.
WEAR SELF-CONTAINED BREATHING APPARATUS, RUBBER BOOTS AND HEAVY
PLACE IN CLOSED CONTAINER.TRANSPORT OUTDOORS. VENT AREA AND
WASHAREA.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP TIGHTLY CLOSED. KEEP AWAY FROM
HEAT, SPARKS, AND OPEN FLAMES. STORE IN COOL, DRY PLACE. KEEP AWY
FROM SOURCES OF IGNITION. NO SMOKING.
Other Precautions:KEEP CONTAINER IN WELL VENTILATED PLACE. DO NOT
BREATHE VAPORS. DANGER OF SERIOUS DAMAGE TO HEALTH BY PROLONGED
EXPOSURE. NEUROLOGICAL HAZARD. HARMFUL VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH-MSHA-APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD. DO NOT BREATHE VAPOR.
Other Protective Equipment:OTHER PROTECTIVE CLOTHING.
Work Hygienic Practices:AVOID CONTACT WITH EYE, SKIN AND CLOTHING. WASH
THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
IRRITANT. NEUROLOGICAL HAZARD.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:=68.9C, 156.F
Melt/Freeze Pt:=-95.C, -139.F
Vapor Pres:132 MM
Vapor Density:3
Spec Gravity:0.659
Appearance and Odor:COLORLESS LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF CARBON MONOXIDE, CARBON
DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER BUT EXERT EXTRA CARE IN IGNITING AS THIS
MATERIAL IS HIGHLY FLAMMABLE. OBSERVE ALL LOCAL, STATE AND FEDERAL
LAWS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PAPER FACED GYPSUM BOARD, PREDEC BLANKS
CAGE:00284
CAGE:00284
============= Composition/Information on Ingredients =============
Ingred Name:CELLULOSE; (PAPER/CELLULOSE FIBER). %:3.5-10.8.
CAS:9004-34-6
RTECS #:FJ5691460
Fraction by Wt: SEE ING
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3
Ingred Name:NUISANCE PARTICULATES (INCLUDING INGS 5, 6, 7)
RTECS #:9999999ZZ
Fraction by Wt: 4-11%
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:VERMICULITE
Fraction by Wt: 4-11%
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:CLAY (KAOLIN)
CAS:1332-58-7
RTECS #:GF1670500
Fraction by Wt: 4-11%
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:ETHYLENE, CHLORO-, POLYMER; (POLYVINYL CHLORIDE)
CAS:9002-86-2
RTECS #:KV0350000
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <1%
OSHA PEL:10 MG/M3 RDUST
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:SULFURIC ACID, CALCIUM SALT (1:1); (GYPSUM/CALCIUM SULFATE
DIHYDRATE) (MAY CONTAIN ING 2)
CAS:7778-18-9
RTECS #:WS6920000
Fraction by Wt: 89%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:PRLNG EXPOS TO HIGH LEVELS OF NUISANCE
DUST MAY CAUSE TRANSIENT SYMPS SUCH AS COUGHING, SNEEZING/NASAL
IRRIT. SYMPS NORMALLY SUBSIDE UPON LEAVING DUSTY AREA. INHAL OF
DUST FROM THESE PRODS HAS NOT BEE N SHOWN TO CAUSE ADVERSE HLTH
EFTS OTHER THAN TRANSITORY SYMPS SUCH AS THOSE DISCUSSED. SOME OF
DUST (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC
MONOGRAPHS, SUPP, VOL 7, PG 341, 1987:GRP 2A. NTP 6TH ANNUAL RPT ON
CARCINS, (SUPP DATA)
Effects of Overexposure:HLTH HAZ:CREATED BY CUTTING,
TRIMMING/PROCESSING OF PROD MAY CONTAIN LOW CONCS OF SILICA, SOME
OF WHICH MAY BE RESPIRABLE. PRLNG EXPOS TO CRYSTALLINE SILICA HAS
BEEN KNOWN TO CAUSE SILICOSIS, LUNG DIS EASE WHICH MAY BE
DISABLING. WHILE THERE MAY BE FACTOR OF INDIVIDUAL SUSCEPTIBILITY
TO GIVEN EXPOS TO RESPIRABLE(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:MOVE TO FRESH AIR TO
RELIEVE NUISANCE SYMPTOMS. EYE:FLUSH THOROUGHLY W/RUNNING WATER FOR
AT LEAST 15 MINUTES, INCLUDING UNDER EYELIDS. SEEK MEDICAL
ATTENTION I F IRRITATION PERSISTS. SKIN:WASH AFFECTED AREA
THOROUGHLY W/WATER.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
NON-COMBUSTIBLE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP/VACUUM SPILLED MATL INTO WASTE CNTNR FOR
DISP. WASH AREA W/WATER. SPILLS/RELS OF THIS MATL DO NOT CURRENTLY
TRIGGER EMER RELS REQUIREMENTS UNDER SARA. STATE & LOC LAWS MAY
DIFFER FROM FED LAW. C ONSULT COUNSEL FOR FURTHER GUIDANCE ON (SUPP
DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE UNDER DRY & LEVEL CONDITIONS.
Other Precautions:POWER SAWING OF THIS PRODUCT IS NOT RECOMMENDED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR IF TOTAL
PARTICULATES EXCEED TLV FOR NUISANCE DUST. PROTECT AGAINST
RESPIRABLE PARTICULATES WHEN HANDLING.
Ventilation:LOCAL EXHAUST:RECOMMENDED, IF TLV FOR NUISANCE DUST IS
EXCEEDED.
Other Protective Equipment:NONE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PH:6.5-8.5. HAZ DECOMP PROD:<5% IN PRODS COVERED BY THIS MSDS. EXPLAN
OF CARCIN:1991:ANTIC TO BE CARCIN. EFTS OF OVEREXP:SILICA DUST,
RISK OF CONTRACTING SILICOSIS & SEVERITY OF DISEASE IS CLEARLY REL
ATED TO AMT OF DUST EXPOS & LGTH OF TIME (USUALLY YRS) OF EXPOS.
SPILL PROC:YOUR RESPONSIBILITIES UNDER THESE LAWS.
================== Physical/Chemical Properties ==================
Spec Gravity:0.7 (H*2O=1)
pH:SUPDAT
Solubility in Water:APPROXIMATELY 0.2%
Appearance and Odor:PAPER FACED GYPSUM BOARD; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:HIGH TEMPS COULD LEAD TO FORM OF VINYL
CHLORIDE MONOMOER AS DECOMP PROD OF POLYVINYL CHLORIDE. PVC IS
PRESENT AT(SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:MAY BE DISPOSED OF AS INERT SOLID IN SANITARY
LANDFILL OR BY OTHER PROCEDURES I/A/W ALL FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LIQUA SAFE
Preparer's Name:REGULATORY
CAGE:EO268
CAGE:73042
CAGE:EO268
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM METASILICATE
CAS:10006-28-7
Fraction by Wt: <20.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM HYPOCHLORITE (CERCLA)
CAS:7681-52-9
RTECS #:NH3486300
Fraction by Wt: >3.0%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NAUSEA. CORROSIVE TO SKIN & EYES.
MISTS ARE CORROSIVE TO SKIN, EYES, RESPIRATORY TRACT.
Medical Cond Aggravated by Exposure:SENSITIVE SKIN & EYES. IMPAIRED
PULMINARY FUNCTIONING.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH THOROUGHLY W/FRESH WATER AT LEAST 15 MINUTES. GET
MEDICAL AID. SKIN: FLUSH W/FRESH WATER. WASH W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING/SHOES. INGESTION: GIVE WATER. DO NOT INDUCE
VOMI TING. GET MEDICAL AID.
===================== Fire Fighting Measures =====================
Flash Point:NA
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:WATER, WATER FOG, DRY CHEMICAL.
Fire Fighting Procedures:WEAR PROTECTIVE GEAR & SCBA IN FIRE AREA.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH SMALL AMOUNTS TO DRAIN. COLLECT & RETURN
LARGE AMOUNTS TO CONTAINER. CERCLA REQUIREMENT - SODIUM
HYPOCHLORITE = 4000 LBS/370 GL.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT PRESSURE CONTAINER TO EMPTY. IF
FROZEN, THAW & MIX TO MAKE USEABLE. KEEP CONTAINER CLOSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH APPROVED RESPIRATOR IF TLV OR PEL
EXPOSURE LIMITS EXCEEDED.
Ventilation:LOCAL VENTILATION.
Other Protective Equipment:NONE
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:215F,102C
Vapor Pres:17.5
Vapor Density:NA
Spec Gravity:1.30
Evaporation Rate & Reference:>1 (BUAC=1)
Solubility in Water:100%
Appearance and Odor:CLEAR, SLIGHTLY YELLOW LIQUID, CHLORINE ODOR
Percent Volatiles by Volume:70.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MINERAL ACIDS; RELEASE CHLORINE.
Hazardous Decomposition Products:CL2
==================== Disposal Considerations ====================
Waste Disposal Methods:USE UNTIL <1 INCH REMAINS IN CONTAINER. EMPTY
CONTAINER. TRIPPLE RINSE W/WATER. DISPOSE TO INDUSTRIAL OR SANITARY
SEWER. REMOVE OR DEFACE LABEL BEFORE SELLING OR DISPOSAL. CONTAINS
PHOSPHATES. ALL CHE MICAL COMPONENTS ON TSCA INVENTORY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BIO SHIELD - OC/CS/CN/CR/DN NEUTRALIZER
CAGE:NO604
CAGE:002Z6
CAGE:NO604
============= Composition/Information on Ingredients =============
Ingred Name:HERBAL EXTRACT
Fraction by Wt: > 67%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHYL ALCOHOL (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: < 3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9596
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: < 29%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS UNKNOWN.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:NONE. ACUTE AND CHRONIC-
NO PHYSICAL EFFECTS AND DAMAGE TO HUMAN SKIN AND BODY HAVE BEEN
INDICATED.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:TESTED FOR SAFETY BY INDEPENDENT FDA APPROVED
LABORATORY IN ACCORDANCE WITH FHSA PROCEDURES IN ALL RESPECTS. NO
PHYSICAL EFFECTS OR DAMAGE TO HUMAN SKIN, EYES OR BODY HAVE BEEN
INDICATED, THEREFORE UN LIMITED AMOUNTS MAY BE USED.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS OCCURS. INHALED:REMOVE TO FRESH
AIR. EYES:FLUSH WITH WATER FOR 15 MINUTES. HOLD EYELIDS OPEN.
SKIN:FLUSH WITH WATER. ORAL:DRINK WATER TO DILUTE.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:NONFLAMMABLE. USE EXTINGUISHING MEDIA SUITABLE FOR
SURROUNDING FIRE.
Fire Fighting Procedures:EXPOSURE TO TEMPERATURES ABOVE 50C IF PRODUCT
IS PACKAGED IN AEROSOL FORM MAY CAUSE SEALS TO LEAK OR RUPTUR. USE
WATER SPRAY TO COOL FIRE-EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. CONSULT LOCAL ENVIRONMENTAL AUTHORITIES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:IF PRODUCT IS PACKAGED IN AEROSOL
FORM, DO NOT PUNCTURE, INCINERATE OR STORE AT TEMPERATURES ABOVE
50C.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:ADEQUATE
Other Protective Equipment:EYE WASH STATION
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
FORMULA CHANGED.
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:186F,85C
Melt/Freeze Pt:M.P/F.P Text:<14F,<-10C
Vapor Pres:17.9 @ 68F
Vapor Density:< 1
Spec Gravity:1.0
Solubility in Water:DISPERSABLE
Appearance and Odor:BROWN LIQUID WITH SMELL OF HERBS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:EXCESSIVE HEAT (TEMPERATURES ABOVE 120F)
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:MASTERPATCH 220 AGGREGATE, 05385(FORMERLY R
CAGE:FO873
CAGE:98898
CAGE:FO873
============= Composition/Information on Ingredients =============
Ingred Name:SILICATE, PORTLAND CEMENT
CAS:65997-15-1
RTECS #:VV8770000
Fraction by Wt: 10-30%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 10-30%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL:NUISANCE DUST MAY CAUSE
TEMPORARY BUT REVERSIBLE RESP PROBLEMS. EYES:ABRASIVE ACTION MAY
CAUSE DMG TO OUTER SURFACE OF EYE. MAY CAUSE SEVERE IRRIT WITH
CORNEAL INJURY. SKIN:IN COMBINATION WITH W ATER DERMAL EXPOS MAY
CAUSE SEVERE ALKALI BURNS. INGEST:NOT APPLICABLE. (CHRONIC) RPTD
INHAL OF RESP (EFTS OF OVEREXP)
Explanation of Carcinogenicity:CRYSTALLINE SILICA: GROUP 2A
(IARC),GROUP 2 (NTP)
Effects of Overexposure:HLTH HAZ: SILICA IN EXCESS OF THE TLV OVER
EXTENDED PERIODS CAN RESULT IN IRREVERSIBLE FIBROSIS OF THE LUNGS
(SILICOSIS).
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. EYES: FLUSH WITH COPIOUS AMOUNTS
OF WATER. CALL MD. SKIN: WASH WITH SOAP AND WATER. INGEST: CALL MD
IMMEDIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:THIS MATL DOES NOT GIVE FL PT BY CONVENTIONAL TEST
METHODS. USE EXTING AGENT SUITABLE FOR TYPE OF SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT APPLICABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:NO SPECIAL PROCEDURES ARE REQUIRED FOR
CLEAN-UP OF SPILLS OR LEAKS OF THIS MATERIAL. SWEEP UP AND RETURN
FOR REUSE OR DISCARD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM WET DAMP CONDITIONS.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED DUST MASKS.
Ventilation:VENT MAY BE USED TO CONTROL OR REDUCE AIRBORNE
CONCENTRATIONS.
Other Protective Equipment:NORMAL CLOTHING. DO NOT WEAR CONTACT LENSES
WHEN WORKING WITH THIS PRODUCT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Solubility in Water:SLIGHT
Appearance and Odor:DARK GRAY GRANULAR POWDER, ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS PRODUCT, WHEN DISCARDED OR DISPOSED OF, IS
NOT LISTED AS A HAZARDOUS WASTE IN FEDERAL REGULATIONS. DISPOSE IN
A LANDFILL IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PRC PRIMER 4 MARINE
CAGE:83574
CAGE:83574
============= Composition/Information on Ingredients =============
Ingred Name:POLYMETHYLENE POLYPHENYL ISOCYANATE; (POLYMETHYLENE
POLYPHENYLENE POLYISOCYANATE) ( CONTAINING ING 2)
CAS:9016-87-9
RTECS #:TR0350000
Fraction by Wt: 40%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ISOCYANIC ACID, METHYLENEDI-P-PHENYLENE ESTER; (METHYLENE
BISPHENYL ISOCYANATE) (MDI) (SARA 313)
CAS:101-68-8
RTECS #:NQ9350000
OSHA PEL:C 0.02 PPM
ACGIH TLV:0.005 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:2-HEPTANONE; (METHYL N-AMYL KETONE). VAP DENS:3.94. EVAP
RATE:0.4. LEL:1.11%. UEL:7.9%
CAS:110-43-0
RTECS #:MJ5075000
Fraction by Wt: 30%
OSHA PEL:100 PPM
ACGIH TLV:50 PPM
Ingred Name:TOLUENE (SARA 313) (CERCLA)
CAS:108-88-3
RTECS #:XS5250000
OSHA PEL:200 PPM; Z-2
ACGIH TLV:S, 50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOLATILE ORGANIC CONTENT:331 G/L
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:EXPOS. IN OPEN AREAS. @ LEAST 100 FEET SHOULD
SEPARATE THIS OPERATION FROM ANY PERSONS NOT PROTECTED AS (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:STATED IN PREVIOUS PARAGRAPH. INSIDE SPRAY APPLIC
SHOULD BE IN AREA SEPARATED FROM OTHER WORK AREAS BY (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:WALLS & VENTILATED BY LOCAL VENT, PROPERLY DESIGNED &
OPERATED I/A/W ACGIH GUIDELINES AS CONTAINED IN ITS (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:INDUST VENT PUBLICATION/OTHER APPROP COLLECTION SYS
TO COLLECT ANY OVERSPRAY. UNPROTECTED PERSONS MUST (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:BE PVNTD FROM CONTACTING UNCURED RESIDUE ON EQUIP &
AREA SURF UNTIL PROD HAS CURED. THIS PROD CONTAINS (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:TOLUENE WHICH IS KNOWN BY ST OF CA TO CAUSE REPROD
TOX. AVOID MOISTURE CONTAM WHICH WILL CAUSE CO*2 (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:PRESS. DO NOT RESEAL CNTNRS IF MOISTURE CONTAM IS
SUSPECTED. PROD CONTAINS TOX CHEM/CHEMS SUBJECT TO RPTG(ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:REQUIREMENTS OF SECTION 313 OF TITLE III OF
SUPERFUND AMENDMENTS & REAUTHORIZATION ACT OF 1986 & 40CFR PART
372.
RTECS #:9999999ZZ
Ingred Name:VENT:TO PRODUCE AIRBORNE LEV OF ISOCYANATE/SOLV IN EXCESS
OF TLV, USE NIOSH/MSHA AIR-SUPPLIED RESPIRATOR.
RTECS #:9999999ZZ
Ingred Name:EYE PROT:LENGTH FACESHIELD .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES:IRRIT, WATERING & POSS
REVERSIBLE CORNEAL DMGE. SKIN:LOCAL IRRIT & DISCOLORATION. MAY
CAUSE ALLERGIC SKIN RASH IN SENSITIZED INDIVIDUALS. INHAL:DUE TO
LOW VOLATILITY, SIGNIFICANT EXPOS TO V APS IS NOT EXPECTED UNLESS
OVERHEATED. EXCESSIVE INHAL CAN PRODUCE IRRIT OF NOSE, THROAT &
RESP TRACT. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:EXCESSIVE & EXTENSIVE EXPOS CAN
PRODUCE REVERSIBLE SYMP OF BRONCH. PERSONS W/PRE-EXISTING RESP
CNDTNS MAY BE ADVERSELY AFFECTED @ CONC BELOW PEL. SENSITIZED
INDIVIDUALS WILL DEVELOP ASTHMA-LI KE SYMP @ LOW EXPOS. INGEST:MAY
RSLT INIRRIT & SOME CORR ACTION IN MOUTH, STOM TISS & DIGESTIVE
TRACT. TOLUENE (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/LUKE-WARM WATER FOR @ LEAST 15 MINS. CONSULT
PHYS. SKIN:IMMED WASH W/SOAP & WATER. REMOVE CONTAMD CLTHG &
LAUNDER PRIOR TO REUSE. IF IRRIT PERSISTS, CONSULT PHYS.
INHAL:REMOVE TO FRESH AI R. IF RESP SYMP ARE PRESENT, CONSULT PHYS.
INGEST:GIVE MILK/WATER TO DRINK. DO NOT INDUCE VOMIT. CONSULT PHYS.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:114F,46C
Lower Limits:SEE ING 3
Upper Limits:SEE ING 3
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED AIR SUPPLIED
RESPIRATOR. SUE WATER TO COOL HEAT-EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:HIGH TEMPERATURES MAY CAUSE PRESSURE
BUILDUP IN CLOSED CONTAINERS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH/MSHA AIR-SUPPLIED RESP FOR MAJOR
UNVENTILATED SPILL. COVER W/ABSORB MATL, ADD DECONTAM SOLN & ALLOW
TO REACT FOR 10 MINS. COLLECT IN CNTNRS, ADD ADDNL DECONTAM SOLN &
KEEP LOOSELY COVERED 4 8 HRS. CLEAN UP RESIDUE
W/1,1,1-TRICHLOROETHANE.
Neutralizing Agent:DECONTAMINATION SOLN:5% CONC AMMONIA, 2% DETERGENT,
93% WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:NOTE:DURING SPRAY APPLIC, STRINGENT
PRECAUT MUST BE TAKEN TO ENSURE SFTY OF PERSONS INVOLVED W/APPLIC,
OTHER PERSONS WORKING IN AREA, & GEN PUBLIC.
Other Precautions:WHEN SPRAY APPLYING, USER MUST BE FULLY PROTECTED
FROM CONT W/ANY OF MATL. FULL, PERMEATION RESIST, PROT SUIT INCLDG
NIOSH/MSHA AIR-SUPPLIED RESP MUST BE USED. OTHER (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED AIR-SUPPLIED RESPIRATOR.
Ventilation:GEN VENT TO MAINTAIN VAPS BELOW TLV. WHEN SPRAYING,
APPLYING IN CONFINED AREAS/IN OTHER CIRCUMSTANCES LIKELY (ING 14)
Other Protective Equipment:EMERGENCY EYE WASH & DELUGE SHOWER WHICH
MEET ANSI DESIGN STANDARDS .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:APPEARS ON NAVY LIST OF OCCUP CHEM REPROD HAZ. SEEK
CONSULTATION FROM APPROP HLTH PROFESSIONALS CONCERNING LATEST HAZ
LIST INFO & SAFE HNDLG & EXPOS INFO . OTHER PRECAUT:PERSONS
ENTERING AREA FOR ANY REASON MUST BE SIMILARLY PROTECTED. SPRAY
APPLIC SHOULD BE ISOLATED TO REDUCE POTNTL FOR (ING 6)
================== Physical/Chemical Properties ==================
Vapor Density:SEE ING 3
Spec Gravity:1.02
Evaporation Rate & Reference:SEE INGREDIENT 3
Solubility in Water:SLIGHT
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, ALCOHOLS, STRONG BASES, AMINES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OXIDES OF CARBON & NITROGEN, POSSIBLE
TRACES OF HCN.
==================== Disposal Considerations ====================
Waste Disposal Methods:EPA WASTE NO. D-001. DISPOSE OF SPILLAGE IN
COMPLIANCE WITH FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:7522/4
CAGE:53021
CAGE:00853
CAGE:53021
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR.AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UNC ONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MOGULAB HARDNESS CI #1348
CAGE:EO676
CAGE:57294
CAGE:EO676
============= Composition/Information on Ingredients =============
Ingred Name:GLYCOL ETHERS, DIETHYLENE GLYCOL, 2,2-OXYBISETHANOL
CAS:111-46-6
RTECS #:ID5950000
Fraction by Wt: >99%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MUCOUS MEMBRANES
IRRITATION. INGESTION: NAUSEA, VOMITING. SKIN: POSSIBLE DERMATITIS.
OTHER: RENAL AND HEPATIC DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: MUCOUS MEMBRANES IRRITATION.
INGESTION: NAUSEA, VOMITING. SKIN:POSSIBLE DERMATITIS. OTHER:
RENAL AND HEPATIC DAMAGE.
======================= First Aid Measures =======================
First Aid:SKIN: FLUSH W/WATER, THEN WASH THOROUGHLY W/SOAP & WATER.
EYES: FLUSH W/WATER FOR 15 MINS. INGESTION: DRINK PLENTY OF WATER.
AVOID ALCOHOLIC BEVERAGES. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:225F
Extinguishing Media:CO2, DRY CHEMICAL, FOAM OR WATER FOG
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP & FLUSH W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT W/SKIN & EYES. DON'T
TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USUALLY NOT REQUIRED
Ventilation:GOOD GENERAL
Other Protective Equipment:RUBBER APRON
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:244F
Spec Gravity:1.118
pH:6.3
Solubility in Water:COMPLETE
Appearance and Odor:DARK RED LIQUID ODOR.
Percent Volatiles by Volume:>99%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALUMINUM
Stability Condition to Avoid:EXCESSIVE HEAT
==================== Disposal Considerations ====================
Waste Disposal Methods:DILUTE W/WATER & FLUSH TO SEWER.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:CONATHANE EN-1556 PART A URETHANE PREPOLYMER
Kit Part:Y
Preparer's Name:GEORGE C. KARPIN
CAGE:16245
INC.
CAGE:16245
CAGE:2B613
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE-2,4-DIISOCYANATE (TDI) (SARA 302/313) (CERCLA)
CAS:584-84-9
RTECS #:CZ6300000
Fraction by Wt: <10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 0.02 PPM
ACGIH TLV:0.005PPM/0.02STEL;96
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:MANUFACTURER DID NOT LIST ANY OTHER INGREDIENTS. THE
REMAINDER IS THUS ASSUMED TO BE "NOT HAZARDOUS" BY OSHA DEFINITION
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS >2000 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION OVEREXPOSURE MAY CAUSE
ALLERGIC RESPIRATORY REACTION. INHALATION OVEREXPOSURE MAY CAUSE
IRRITATION OF THE RESPIRATORY TRACT AND EYES. REPEATED OR PROLONGED
DERMAL CONTACT WITH THIS MATERIAL MAY CAUSE ALLERGIC SKIN
REACTION. DIRECT CONTACT WITH THIS MATERIAL MAY CAUSE MODERATE EYE
AND SKIN IRRITATION.
Explanation of Carcinogenicity:CONTAINS TOLUENE DIISOCYANATE (TDI).
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN-IMMEDIATELY WASH AFFECTED AREA WITH SOAP & WATER. REMOVE
SOILED CLOTHES/SHOES. OBTAIN MEDICAL AID. EYE-IMMEDIATELY IRRIGATE
WITH PLENTY OF WATER FOR 15 MIN. OBTAIN MEDICAL AID. INHALE-REMOVE
FROM EXPOSURE. ADMINISTER OXYGEN IF HRAD TOBREATH. GIVE ARTIFICIAL
RESPIRATION IF NOT BREATHING & CONTINUE UNTIL NORMAL BREATHING IS
ESTABLISHED. OBTAIN MEDICAL AID WITHOUT DELAY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>200F,>93C
Extinguishing Media:USE CARBON DIOXIDE, DRY CHEMICAL, WATER SPRAY, OR
ALCOHOL FOAM TO EXTINGUISH FIRES.
Fire Fighting Procedures:WEAR SELF-CONTAINED POSITIVE PRESSURE
BREATHING APPARATUS AND FULL FIREFIGHTING PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:WATER/ALCOHOL FOAM MAY REACT VIGOROUSLY
WITH HOT ISOCYANATE, RELEASING CARBON DIOXIDE. DO NOT RESEAL
CONTAMINATED CONTAINERS SINCE PRESSURE BUILD-UP MAY RUPTURE
================== Accidental Release Measures ==================
Spill Release Procedures:WHERE EXPOSURE LEVEL IS UNKNOWN, WEAR NIOSH
APPROVED, POSITIVE PRESSURE, SELF-CONTAINED RESPIRATOR. COVER
SPILLS WITH SOME INERT ABSORBENT MATERIAL; SWEEP UP & PLACE IN A
WASTE DISPOSAL CONTAINER. FLU SH AREA WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & FLAMES.
AVOID BREATHING VAPOR. AVOID PROLONGED OR REPEATED CONTACT WITH
SKIN. AVOID CONTACT WITH EYES.
Other Precautions:USE WITH ADEQUATE VENTILATION. DO NOT ALLOW WATER OR
OTHER LIQUIDS TO GET INTO CONTAINER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE EXPOSURES ARE BELOW THE PEL, NO
RESPIRATORY PROTECTION IS REQUIRED. WHERE EXPOSURES EXCEED THE PEL
USE RESPIRATOR APPROVED BY NIOSH FOR THE MATERIAL AND LEVEL OF
EXPOSURE.
Ventilation:GOOD ENCLOSURE AND LOCAL EXHAUST VENTILATION SHOULD BE
PROVIDED TO CONTROL EXPOSURE.
Other Protective Equipment:APRON, WORKPANTS, LONG SLEEVE WORK SHIRT OR
DISPOSABLE COVERALLS ARE RECOMMENDED TO PREVENT SKIN CONTACT.
Work Hygienic Practices:SHOWER AFTER COMPLETION OF WORKSHIFT. LAUNDER
WORK CLOTHING AT END OF WORKSHIFT PRIOR TO REUSE. STORE CLOTHES
SEPERATELY
Supplemental Safety and Health
FOOD, BEVERAGES AND TOBACCO PRODUCTS SHOULD NOT BE CARRIED, STORED OR
CONSUMED WHERE THIS MATERIAL IS IN USE. EYE WASH EQUIPMENT AND
SAFETY SHOWER SHOULD BE PROVIDED IN AREAS OF POTENTIAL EXPOSURE.
================== Physical/Chemical Properties ==================
HCC:T4
Spec Gravity:1.06
Evaporation Rate & Reference:<1
Solubility in Water:REACTS WITH WATER.
Appearance and Odor:AMBER LIQUID; CHARACTERISTIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CAN REACT WITH WATER TO BUILD UP PRESSURE IN CLOSED CONTAINERS. AVOID
ACIDS, BASES, STRONG AMINES, OXIDIZERS, & WATER.
Stability Condition to Avoid:NONE KNONW.
Hazardous Decomposition Products:THERMAL DECOMPOSITION OR COMBUSTION
MAY PRODUCE CARBON DIOXIDE, CARBON MONOXIDE AND/OR OXIDES OF
NITROGEN.
Conditions to Avoid Polymerization:CAN REACT WITH WATER TO BUILD UP
PRESSURE IN CLOSED CONTAINERS. AVOID ACIDS, BASES, STRONG AMINES,
OXIDIZERS AND WATER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE MADE IN ACCORDANCE WITH
APPLICABLE GOVERNMENTAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: ACID ALCOHOL 1%, S104
Cage: 67458
=======================================================
Contractor Summary
=======================================================
Cage: 67458
=======================================================
Ingredients
=======================================================
Cas: 7647-01-0
RTECS #: MW4025000
LD50:(ORAL,RAT) 900 MG/KG
OSHA PEL: C 5 PPM
ACGIH TLV: C 5 PPM
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Cas: 64-17-5
RTECS #: KQ6300000
OSHA PEL: 1000 PPM
ACGIH TLV: 1000 PPM
------------------------------
Cas: 67-56-1
RTECS #: PC1400000
OSHA PEL: S, 200 PPM
ACGIH TLV: S, 200 PPM/250 STEL
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 67-63-0
RTECS #: NT8050000
OSHA PEL: 400 PPM
ACGIH TLV: 400 PPM/500 STEL
------------------------------
Cas: 108-10-1
RTECS #: SA9275000
OSHA PEL: 100 PPM
ACGIH TLV: 50 PPM/75 STEL
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: SEE INGREDIENT 1
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: EROSION OF TEETH, POISONING, NAUSEA AND VOMITING.
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
First Aid: INHAL: REMOVE TO FRESH AIR. EYES: FLUSH WITH COPIOUS AMOUNTS OF
WATER FOR AT LEAST 15 MINUTES. SKIN: WASH WITH COPIOUS AMOUNTS OF WATER AT
LEAST 15 MINUTES. INGEST: DO NOT INDUCE VOMITING, GIVE LARGEQUANTITIES OF
WATER OR MILK, GET MEDICAL ATTENTION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: ISOLATE OR ENCLOSE AREA. NEUTRALIZE WITH ALKALINE
MATERIAL (LIME, SODA ASH). TAKE UP WITH VERMICULITE AND CONTAINERIZE FOR
PROPER DISPOSAL.
Neutralizing Agent: ALKALINE MATERIAL (LIME, SODA ASH).
Waste Disposal Methods: COMPLIANCE WITH LOCAL STATE FEDERAL REGULATIONS.
Handling And Storage Precautions: STORE IN COOL, DRY, VENTILATED AREA. PROTECT
FROM PHYSICAL DAMAGE AND DIRECT SUNLIGHT.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: CC
Flash Point Text: 56.0F,13.3C
Lower Limits: 3.3%
Upper Limits: 19%
Extinguishing Media: ALCOHOL TYPE FOAM OR WATER SPRAY.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). CL REACTS WITH WATER TO PRODUCE HEAT & TOXIC &
CORROSIVE FUMES. CO & CO*2 POISONING FROM ALCOHOL.
Unusual Fire/Explosion Hazard: CAN REACT WITH METALS TO RELEASE HYDROGEN GAS.
ETHANOL VAPS ARE EXPLOSIVE ABOVE FLAMMABLE LIMITS. CONT W/STRONG OXIDANTS MAY
CAUSE FIRE OR EXPLOSION.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH APPROVED SELF CONTAINED BREATHING APPARATUS.
Ventilation: LOCAL EXHAUST.
Other Protective Equipment: ANSI APPRVD EYE WASH & DELUGE SHOWER (FP N).
PROTECTIVE APRON.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: MATLS TO AVOID: NITRIC ACID, BROMINE, HYDROGEN
PEROXIDE. EYE PROT: & FULL LENGTH FACESHIELD (FP N).
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >169F,>76C
Vapor Pres: 52
Vapor Density: 1.6
Spec Gravity: 0.791
Evaporation Rate & Reference: 3.8 (RATE =1)
Solubility in Water: YES
Appearance and Odor: CLEAR COLORLESS LIQUID, CHARACTERISTIC ODOR.
Percent Volatiles by Volume: 100
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEAT, SPARKS, AND FIRES.
Materials To Avoid: BASES, OXIDIZERS, CALCIUM CARBIDE, MAGNESIUM, CYANORIC
CHLORIDE, CYANIDES, SULFIDES, SULFITES, FORMALDEHYDE, (SUPDAT)
Hazardous Decomposition Products: TOXIC HYDROGEN CHLORIDE FUMES.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: ACID ALCOHOL 1%, S104
Cage: 67458
Company Name: POLY SCIENTIFIC R&D CORP.
Street: 70 CLEVELAND AVE
Zipcode: 11706
Label Required IND: Y
Date Of Label Review: 01/29/1998
Status Code: C
Label Date: 01/29/1998
Origination Code: G
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Severe
Contact Hazard: Severe
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE. CORROSIVE. ACUTE: EROSION OF TEETH,
POISONING, NAUSEA AND VOMITING. CHRONIC: NONE LISTED BY MANUFACTURER.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BIG JOE
CAGE:86938
CAGE:86938
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM METASILICATE
CAS:6834-92-0
RTECS #:VV9275000
Ingred Name:POTASSIUM METASILICATE
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
OSHA PEL:C, 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:EYE/SKIN: IRRITATION.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH WITH WATER 15 MINUTES,CONSULT PHYSICIAN IF
IRRIATAION PERSISTS. SKIN: WASH WITH SOAP & WATER. INGESTION: DRINK
PLENTY OF WATER,INDUCE VOMITING AND GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:SELF-CONTAIN BREATH APP
Unusual Fire/Explosion Hazard:NONE (MFR)
================== Accidental Release Measures ==================
Spill Release Procedures:MOP UP WITH WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL REQUIREMENTS
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED (MFR)
Ventilation:GENERAL
Other Protective Equipment:AS REQUIRED TO PREVENT SKIN & CLOTHING
CONTACT.
Supplemental Safety and Health
SODIUM & POTASSIUM METASILICATE COMPRISE 20-30% OF PRODUCT & SODIUM &
POTASSIUM HYDROXIDES ARE 1-2% OF PRODUCT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:200F/93C
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR,ALMOST COLORLESS,ODORLESS.
Percent Volatiles by Volume:73
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDIC MATERIALS
Hazardous Decomposition Products:NONE (MFR)
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH DOWN DRAIN WITH PLENTY OF WATER,COMPLY
WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:3M BRAND ACTIVATOR
CAGE:76381
CAGE:76381
DIV
CAGE:1BY21
============= Composition/Information on Ingredients =============
Ingred Name:MAGNESIUM ACETATE (WT% RANGE 80-90%)
CAS:142-72-3
RTECS #:AI5600000
Fraction by Wt: 10%.
Ingred Name:ETHYLENE THIOUREA/SILVER COMPLEX (WT% RANGE 1-5%
Fraction by Wt: 5%
Ingred Name:ETHYLENE THIOUREA (SARA III)
CAS:96-45-7
RTECS #:NI9625000
Fraction by Wt: 0.2%
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 85%
Ingred Name:ACETIC ACID (SARA III)
CAS:64-19-7
RTECS #:AF1225000
Fraction by Wt: <1.0%
Other REC Limits:NONE SPECIFIED
OSHA PEL:10 PPM
ACGIH TLV:10 PPM/15 STEL; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:IRRITATION.ETHYLENE THIOUREA PROBABLE
HUMAN CARCINOGEN, NO HUMAN EVIDENCE.
Effects of Overexposure:EYE:IRRT.SKN:NONE EXPECTED.INHL:NONE,INGEST;
REPTD EXPOSURE HAS CAUSED CANCER,BIRTH DEF IN LAB ANMLS
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:INHAL:RMV TO FRESH AIR. IF NOT BRTHNG GIVE CPR; IF BRTHNG
DIFF GIVE OXYGEN. EYE:IMMED FLUSH W/PLENTY OF WATER. SKIN:WASH
W/SOAP&WATER. RMV CONTAM CLTHG&SHOES. INGEST:INDUCE VOMIT. RPT
UNTIL VOMIT IS C LEAR. NOTHG BY MOUTH IF UNCONSC. GET MEDICAL ATTN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:CAREFULLY OBSERVE PRECAUTIONS FROM OTHER
SECTIONS. COLLECT SPILLED MATERIAL. FLUSH AA WITH LARGE AMOUNTS OF
WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT FROM FREEZING.
Other Precautions:AVOID EYE,SKN CONTACT. DO NOT INHALE OR INGEST. WASH
AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Ventilation:GEN MECHANICAL
Other Protective Equipment:NONE
Supplemental Safety and Health
UPDATE PER 3M MSDS DOC#10-3571-6 DATED 1NOV85. 3M ID# IS 78-9020-0080-7
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:215F
Spec Gravity:1.03
pH:4.7-5.
Evaporation Rate & Reference:1.0 (WATER=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR SOLUTION, VINEGAR ODOR. PH=4.7-5.3
Percent Volatiles by Volume:>85
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:NEUTRALIZE ACID WITH SODIUM HYDROXIDE OR
POTASSIUM HYDROXIDE. REMOVAL OF SILVER BY A CONVENTIONAL SILVER
REMOVAL PROCEDURE. SLOWLY DISCHARGE SOLUTION TO DRAIN WITH EXCESS
WATER. OR, SEND TO NEAREST HA ZARDOUS WASTE MANAGEMENT FACILITY FOR
DISPOSAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TONER DRY INK
CAGE:JO775
CAGE:JO775
CAGE:57886
============= Composition/Information on Ingredients =============
Ingred Name:TONER DRY INK
Fraction by Wt: >99%
ACGIH TLV:NOT SPECIFIED
===================== Hazards Identification =====================
Effects of Overexposure:NONE KNOWN TO MFR;MAY IRRITATE EYES AND
SKIN;AVOID SKIN CONTACT;DO NOT TAKE BY MOUTH
======================= First Aid Measures =======================
First Aid:USE NORMAL FIRST AID PROCEDURES;CALL A DOCTOR IF NECESSARY.
===================== Fire Fighting Measures =====================
Extinguishing Media:NONE NOTED;USE ANY MEDIA FOR SURROUNDING FIRES
Fire Fighting Procedures:NONE NOTED;USE NIOSH APPROVED SCBA WITH FULL
PROTECTION
Unusual Fire/Explosion Hazard:NONE NOTED
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION:SWEEP UP OR
VACUUM SPILLED POWDER AND RECOVER FOR PROPER DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN DRY AND VENTILATED AREA.KEEP
CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:AVOID CONTACT WITH SKIN AND EYES.DO NOT BREATHE
POWDER INK.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL REQMNTS UNDER ORDINARY
CONDITIONS/ADEQUATE VENT.
Ventilation:MECH(GEN)OR LOCAL EXHAUST THAT PROVIDES ADEQUATE
VENTILATION
Other Protective Equipment:AS REQUIRED TO PREVENT PROLONGED CONTACT.
Supplemental Safety and Health
MSDS UNDATED
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DRY INK;ESSENTIALLY ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NONE NOTED
Hazardous Decomposition Products:NONE NOTED
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF COLLECTED MATERIAL IN ACCORDANCE WITH
LOCAL,STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:92-85617 QUICKSILVER SPECIAL LUBRICANT 101
CAGE:GO139
CAGE:88907
CAGE:GO139
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM GREASE/OIL
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION, IF INJECTED UNDER
THE SKIN W/HIGH PRESSURE GREASE GUN, NECROSIS COULD RESULT.
INGESTION: IRRITATION, NAUSEA OR DIARRHEA. EYES: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: IRRITATION, IF INJECTED UNDER THE SKIN
W/HIGH GREASE GUN, NECROSIS COULD RESULT. INGESTION: IRRITATION,
NAUSEA OR DIARRHEA. EYES: IRRITATION.
======================= First Aid Measures =======================
First Aid:INGESTION: DON'T INDUCE VOMITING. EYES: FLUSH W/PLENTY OF
WATER FOR 15 MIN. SKIN: WASH W/SOAP & WATER. HIGH PRESSURE
INJECTION REQUIRED IMMEDIATE MEDICAL ATTENTION. OBTAIN MEDICAL
ATTENTION IN ALL CA SES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, DRY CHEMICAL OR FOAM
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS
W/POSITIVE PRESSURE.
Unusual Fire/Explosion Hazard:MAY PRODUCE TOXIC FUMES AT TEMPERATURES
>930F
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP & PLACE IN CONTAINER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE W/STRONG OXIDIZERS. AVOID
EXPOSURE TO EXTREME TEMPERATURES.
Other Precautions:KEEP AWAY FROM CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER NORMAL USE OF PRODUCT.
Ventilation:MECHANICAL (GENERAL): SUFFICIENT.
Other Protective Equipment:NONE UNDER NORMAL CONDITIONS.
Work Hygienic Practices:LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:1.08
Solubility in Water:INSOLUBLE
Appearance and Odor:SMOOTH GREEN PASTE, MILD PETROLEUM ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIALS
Stability Condition to Avoid:HEAT, OPEN FLAMES, TEMPS >930F.
Hazardous Decomposition Products:CO & VARIOUS HYDROCARBONS
==================== Disposal Considerations ====================
Waste Disposal Methods:UTILIZE PERMITTED INDUSTRIAL WASTE DISPOSAL
SITE. COMPLY W/LOCAL, STATE & REGIONAL REGULATIONS. BURNING IS NOT
RECOMMENDED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:P-D-800 C TYPE II
Preparer's Name:J.J. BURGARD
CAGE:82925
CAGE:82925
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA, LIGHT AROMATIC
CAS:64742-95-6
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:OLEY IMIDAZOLINE
CAS:27136-73-8
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM PETROLEUM SULFONATE
CAS:68608-26-4
Other REC Limits:NONE RECOMMENDED
Ingred Name:NONYLPHENOL POLYETHOXATE
CAS:9016-45-9
RTECS #:MD0900000
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV FOR OIL MIST IS 5 MG/M3.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY &
GI TRACTS. ACUTE & CHRONIC- EYES:MAY CAUSE MILD IRRITATION/REDNESS.
SKIN:MILD-MODERATE IRRITATION WITH PROLONGED/REPEATED CONTACT.
INHALE:INHALATION OF VAPORS GE NERATED AT HIGH TEMPERATURES MAY
CAUSE IRRITATION. ORAL:MAY CAUSE NAUSEA, VOMITING & IRRITATION OF
LOWER GI TRACT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES, SKIN, RESPIRATORY AND GASTROINTESTINAL
TRACTS IRRITATION, NAUSEA, VOMITING
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. EYES:RINSE WITH
WATER FOR AT LEAST 15 MINUTES. SKIN:WASH WITH SOAP AND WATER.
INHALATION:MOVE TO FRESH AIR. IF BREATHING IS DIFFICULT, PROVIDE
OXYGEN. IF BRE ATHING STOPPED, PROVIDE ARTIFICIAL RESPIRATION. GET
IMMEDIATE MEDICAL ATTENTION. INGESTION:DO NOT INDUCE VOMITING.
DRINK 4-8 OZ WATER IF CONSCIOUS. RINSE MOUTH THOROUGHLY
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:370F,188C
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL/CARBON DIOXIDE. DON'T
USE DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE
REIGNITED.
Fire Fighting Procedures:KEEP FIRE-EXPOSED CONTAINERS COOL WITH WATER
FOG. WEAR NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS IF
NEEDED.
Unusual Fire/Explosion Hazard:NONE EXPECTED
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE & CONTAIN SPILL. DON'T ALLOW MATERIAL TO
ENTER DRAINS, SEWERS/WATERWAYS. RECOVER FREE LIQUID IF POSSIBLE.
ABSORB REMAINING PRODUCT WITH INERT MATERIAL & PLACE INTO PROPER
CONTAINERS FOR DISPOSAL. ALL RESPONSE ACTIVITIES MUST COMPLY WITH
HAZWOPER
Neutralizing Agent:NOT RELEVENT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE. KEEP
CONTAINERS CLOSED WHEN NOT IN USE.
Other Precautions:CLEAN CONTAMINATED EQUIPMENT BEFORE STARTING ANY
REPAIR WORK. AVOID PROLONGED OR REPEATED BREATHING OF MISTS OR
VAPORS. DISCARD OIL-SOAKED LEATHER PRODUCTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF WORKING IN A CONFINED AREA OR MISTING IS
OCCURING, USE NIOSH-APPROVED RESPIRATORY PROTECTION.
Ventilation:LOCAL EXHAUST: YES; MECHANICAL - FAN
Other Protective Equipment:FULL COVER SHIRT AND PANTS TO MINIMIZE SKIN
CONTACT. EMERGENCY SHOWERS AND EYE WASH STATIONS IN THE WORK PLACE.
Work Hygienic Practices:AVOID EYE/SKIN CONTACT. ALL USERS CONSULT MSDS
BEFORE HANDLING THIS PRODUCT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NOT RELEVENT
Boiling Pt:B.P. Text:300F,149C
Spec Gravity:0.92
Solubility in Water:COMPLETE
Appearance and Odor:OPAQUE LIQUID, CHARACTERISTIC PETROLEUM ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS SUCH AS LIQUID CHLORINE AND CONCENTRATED OXYGEN
Stability Condition to Avoid:FLAME, EXCESSIVE HEAT, FIRE
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN COMPLIANCE WITH LOCAL, STATE
AND FEDEAL REGULATIONS. RECYCLE WASTE WHERE APPLICABLE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:793-800
CAGE:92216
CAGE:92216
============= Composition/Information on Ingredients =============
Ingred Name:ISOBUTYL ACETATE (SARA III)
CAS:110-19-0
RTECS #:AI4025000
Fraction by Wt: 25.0%
OSHA PEL:150 PPM
ACGIH TLV:150 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOBUTYL ALCOHOL (SARA III)
CAS:78-83-1
RTECS #:NP9625000
Fraction by Wt: 15.0%
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ALIPHATIC NAPHTHA
RTECS #:SE7525000
Fraction by Wt: 15.0%
ACGIH TLV:200 PPM
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 15.0%
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: <5%
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
===================== Hazards Identification =====================
Effects of Overexposure:INHAL:ANESTHETIC & IRRIT. TO AIRWAYS; IRRIT
SKIN/EYE CONTACT;HEADACHE,DIZZY, COMA
======================= First Aid Measures =======================
First Aid:SKIN/EYES: FLUSH W/PLENTY OF WATER WHILE REMOVING
CONTAM.CLOTHING. IF INHAL: REMOVE TO FRESH AIR. CALL DR. IF
SYMPTONS PERSISTS.
===================== Fire Fighting Measures =====================
Flash Point:13 F, -11 C, TCC
Lower Limits:0.9
Extinguishing Media:CARBON DIOXIDE/DRY CHEMICAL-SMALL; POLYMER
FOAM-LARGE FIRE
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS ABAILABLE
FOR FIREMEN.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS EXPOSED TO HEAT MAY
EXPLODE DUE TO PRESSURE BUILD-UP, USE H*2O TO COOL CLOSED CANS
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION (FLAMES, HOT
SURFACES, & ELECTRICAL, STATIC, OR FRICTIONAL SPARKS). AVOID
BREATHING VAPORS. VENTILATE AREA. REMOVE WITH INERT ABSORBENT AND
NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. STORE LARGE
AMTS. IN BUILDINGS DESIGNED AND PROTECTED FOR STORAGE OF NFPA CLASS
ONE FLAMMABLE (OR COMBUSTIBLE) LIQUID.
Other Precautions:DO NOT TAKE INTERNALLY, CONTAINERS SHOULD BE GROUNDED
WHEN POURING,AVOID FREE FALL IN EXCESS OF A FEW INCHES,DO NOT FLAME
CUT,BRAZE, OR WELD COATED MATERIAL WITHOUT VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:APPROVED BUREAU OF MINES RESPIRATORS W/PROPER
FILTER OR HOOD
Ventilation:GENERAL DILUTION/LOCAL EXHAUST FOR TLV&LEL SAFETY & WELDING
Other Protective Equipment:PREVENT PROLONGED SKIN CONTACT TO
CONTAMINATED CLOTHING.
Supplemental Safety and Health
BOILING RANGE 79-143C, TOLUENE < 5%,VM&P NAPHTHA < 5%, CELLOSOLUE
ACETATE < 0.5%
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:174-290 F
Evaporation Rate & Reference:< ETHER
Appearance and Odor:CLEAR LIQUID
Percent Volatiles by Volume:80.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:FIRES, HEAT, & HOT SURFACES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IAW LOCAL, STATE AND FED. REGULATIONS.
INCINERATE IN APPROVED FACILITY. DO NOT INCINERATE CLOSED
CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:C-12 RESINEATER
CAGE:0SPP4
CAGE:0SPP4
============= Composition/Information on Ingredients =============
Ingred Name:2-PYRROLIDIONE OR N-METHYLPYRROLIDONE
CAS:872-50-4
RTECS #:UY5790000
Fraction by Wt: >30%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TARKSOL 97 OR ALPHA TERPINEOL
CAS:98-55-5
RTECS #:WZ6700000
Fraction by Wt: <40%
Other REC Limits:NONE RECOMMENDED
Ingred Name:PENTANEDIOIC ACID, DIMETHYL ESTER (MIXED WITH INGREDIENT #4
MAKES >30% OF PRODUCT)
CAS:1119-40-0
Fraction by Wt: <30%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIMETHYL ADIPATE, METHYL ADIPATE, HEXANEDIOIC ACID DIMETHYL
ESTER (MIXED WITH INGEDIENT #3 MAKES >30% PRODUCT)
CAS:627-93-0
RTECS #:AV1645000
Fraction by Wt: <30%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS UNKNOWN.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SKIN AND EYE IRRITATION.
INHALATION MAY CAUSE IRRITATION TO MUCOUS MEMBRANES IF INHALED.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:EYES: IRRITATION. SKIN: IRRITATION. INHALATION:
IRRITATION OF MUCOUS MEMBRANES.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:IN ALL CASES GET MEDICAL ATTENTION. EYES-FLUSH WITH WATER FOR
15 MINUTES. SKIN-REMOVE CONTAMINATED CLOTHES. WASH WITH MILD SOAP &
WATER. INHALED-REMOVE TO FRESH AIR. INGESTED-DO NOT INDUCE
VOMITING! I F CONSCIOUS, GIVE MILK OR WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>200F,>93C
Extinguishing Media:DRY CHEMICAL, FOAM, CARBON DIOXIDE.
Fire Fighting Procedures:USE BLANKET OR SMOTHER AFFECT TO PUT OUT FIRE.
WATER IS MOST EFFECTIVE WHEN USED IN A MIST.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEANUP PERSONNEL MUST WEAR PROPER PROTECTIVE
EQUIPMENT. RECLAIM MATERIAL INTO CLOSED CONTAINER FOR POSSIBLE
NORMAL USE OR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL PLACE AWAY FROM HEAT
AND FLAMES. PRODUCT MAY CAUSE SOME AFFECT TO PAINTED SURFACES. USE
SOLVENT RESISTANT EQUIPMENT.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE
OR AN EMERGENCY OCCURS; WEAR AN MSHA/NIOSH APPROVED RESPIRATOR WITH
ORGANIC VAPOR CARTRIDGE OR AN AIR-SUPPLIED RESPIRATOR OR SCBA, AS
REQUIRED. USE IAW 29 CFR 1910.134.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION OR LOCAL EXHAUST TO
MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:RUBBER BOOTS AND APRON RECOMMENDED.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NON-REGULATED CLEANING COMPOUND.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:424F,218C
Vapor Density:<1 (AIR=1)
Spec Gravity:0.995
Solubility in Water:SLIGHT
Appearance and Odor:CLEAR LIQUID. FAINT PINE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SUDDEN SHINE T-400
CAGE:33937
CAGE:33937
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2-BUTYOXY-, PHOSPHATE
(3:1);(TRIBUTOXYETHYLPHOSPHATE)
CAS:78-51-3
RTECS #:KJ9800000
Fraction by Wt: 3.9%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IN POORLY VENTILATED AREAS POSSIBLE
IRRITATION OF MUCOUS MEMBRANES.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:EYE CONTACT MAY RESULT IN IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE TO FRESH AIR. EYE:WASH WITH WATER FOR AT LEAST 15
MINUTES. CALL MD. SKIN:WASH WITH SOAP & WATER. INGEST:GIVE WATER TO
DRINK. CALL MD.
===================== Fire Fighting Measures =====================
Flash Point:NON-COMBUSTIBLE
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT APPLICABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE AND CONTAIN SPILL WITH SAND, EARTH, ETC.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:MAINTAIN TEMPERATURE BETWEEN 34 AND
120F.
Other Precautions:NOT APPLICABLE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED. NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:NOT APPLICABLE.
Work Hygienic Practices:NOT APPLICABLE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:<20
Vapor Density:>1
Spec Gravity:1.02 (H*2O=1)
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:INFINITE
Appearance and Odor:MILKY WHITE LIQUID, MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NOT APPLICABLE.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:NOT APPLICABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:LAND FILL. DISPOSAL MUST BE IN ACCORDANCE WITH
LOCAL, STATE AND FEDERAL REGULATIONS .
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:VACUTAINER BRAND WHOLE BLOOD TUBES 6450
Preparer's Name:FU-CHUNG LIN, PH.D
CAGE:7W260
CAGE:TO491
CAGE:7W260
============= Composition/Information on Ingredients =============
Ingred Name:EDTA TRIPOTASSIUM SALT
CAS:17572-97-3
RTECS #:MC0372000
= Wt:15.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRIMARY ROUTES OF ENTRY: EYE:YES.
ACUTE/CHRONIC: THE TOXICOLOGICAL PROPERTIES OF THIS CHEMICAL HAVE
NOT BEEN INVESTIGATED.
Effects of Overexposure:EYES: IRRITATION OR CORROSIVE ACTION WITH
CONTACT. SKIN: IRRITATION OR CORROSIVE ACTION WITH CONTACT.
Medical Cond Aggravated by Exposure:NOT DETERMINED.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH EYES WITH WATER FOR AT LEAST 15
MINUTES. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHES
AND FLUSH SKIN WITH LARGE AMOUNTS OF WATER. IF IRRITATION PERSISTS,
CONTACT PH YSICIAN. INHALATION: REMOVE TO FRESH AIR, GIVE O*2.
INGESTION: SEEK IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NOT DETERMINED
Autoignition Temp:Autoignition Temp Text:N/D
Lower Limits:N/D
Upper Limits:N/D
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SELF CONTAINED BREATHING
APPARATUS AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE (MFR).
================== Accidental Release Measures ==================
Spill Release Procedures:FOR SMALL LIQUID SPILLS, USE ABSORBENT AND
PLACE INTO CONTAINERS FOR LATER DESTRUCTION AND DISPOSAL. WASH
SPILL AREA WITH SOAP AND WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AND HANDLE ACCORDING TO PACKAGED
INSTRUCTIONS. BE PREPARED BEFORE THE NEED ARISES TO CLEAN-UP THE
SPILLED OR SPENT SOLUTION.
Other Precautions:REMOVE CONTAMINATED CLOTHING; WASH THOROUGHLY AFTER
CONTACT WITH LIQUID.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATORY PROTECTION IS NOT REQUIRED UNDER
NORMAL AND INTENDED USES.
Ventilation:GENERAL ROOM VENTILATION.
ELECTIVELY.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER . EMERGENCY EYE BATH IS RECOMMENDED WHERE THERE IS A
POSSIBILITY OF EYE CONTACT.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING; WASH THOROUGHLY
AFTER CONTACT WITH LIQUID.
Supplemental Safety and Health
REACTIVITY IN WATER: NOT REACTIVE. INGREDIENTS: THE INGREDIENTS OF THIS
MIXTURE DO NOT EXIST IN CONCENTRATIONS GREATER THAN THOSE DESCRIBED
IN 29 CFR 1910.1200 (G)(2)(I)(C)(L) AND (2) OR ARE NOT LISTE D IN
SOURCES IDENTIFIED IN 29 CFR 1910.1200 (D)(3) AND (4).
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NOT DETERMINED
Melt/Freeze Pt:M.P/F.P Text:NOT DETERMINED
Vapor Pres:NEGLIGIBLE
Vapor Density:14.0
Spec Gravity:GREATER THAN 1 (AIR=1)
Solubility in Water:APPRECIABLE
Appearance and Odor:WHITE CRYSTALLINE SOLID; NO CHARACTERISTIC ODOR, IF
ANY.
Percent Volatiles by Volume:NEGLIGIBLE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NOT DETERMINED.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY PRODUCE
CARBON MONOXIDE AND/OR CARBON DIOXIDE, NO*X.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTES IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL CODES. INCINERATION MAY BE THE METHOD OF CHOICE.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:03-GY-68 BASE,GRAY 36231,POLYURETHANE
Kit Part:Y
CAGE:HO407
CAGE:33461
CAGE:HO407
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 10.0%
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-ETHOXYETHYL ACETATE (CELLOSOLVE ACETATE) (EGEEA)
CAS:111-15-9
RTECS #:KK8225000
Fraction by Wt: 20.0%
OSHA PEL:S,100 PPM
ACGIH TLV:S, 5 PPM; 9192
Ingred Name:ETHYL ACETATE (CAS #141-78-6)
RTECS #:AH4250000
Fraction by Wt: 10%
ACGIH TLV:400 PPM
Ingred Name:NON-AQUEOUS SOLUTION,HAZARD UNKNOWN,UNIDENTIFIED (% WT BY
DIFFERENCE)
Fraction by Wt: 60.0%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:ACUTE:VAPORS ARE IRRITATING TO
EYES,NOSE AND THROAT.INHALATION MAY CAUSE HEADACHES,DIFFICULT
BREATHING AND LOSS OF CONSCIOUSNESS. CHRONIC:PROLONGED CONTACT WILL
CAUSE DRYING AND CRACKING OF THE SKIN,D UE TO DEFFATING ACTION.SKIN
SENSITIZATION,ASSTHMA OR OTHER ALLERGIC RESPONSES MAY DEVELOP.
Effects of Overexposure:EYES:MODERATE IRRIT;SKIN:POSSIBLE IRRIT BY
SOLVENTS;INH:SOLVENT VAPORS CAN CAUSE IRRIT OR NARCOSIS.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH A HISTORY OF
RESPIRATORY OR SKIN DISEASES MAY BE MORE ADVERSELY AFFECTED.
======================= First Aid Measures =======================
First Aid:SKIN:WIPE OFF WITH A RAG THEN THOROUGH RINSINGW/H*2O &
WASHING W/MILD SOAP AND WATER;EYES:FLUSH W/WATER FOR AT LEAST 10
MIN & CONSULT AN EYE PHYSICIAN;INH:REMOVE TO FRESH AIR.GIVE
CPR/OXYGEN IF NEEDED .
===================== Fire Fighting Measures =====================
Flash Point Method:OC
Flash Point:28.0F,-2.2C
Lower Limits:1.6
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:CAUTION AGAINST APPLICATION TO HOT
SURFACES & USE IN AREASWHERE SOURCES OF IGNITION MAY BE PRESENT.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. STOP LEAK.
EVACUATE AREA.DO NOT TOUCH SPILLAGE. SM SPILL:ABSORB W. INERT
ABSORBENT. PLACE IN CLOSED CONTAINER. FLUSH AREA W. WATER. LG.
SPILL:DIKE AHEAD FOR LATER DISPOSAL. NOTIFY AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENT,LOW FIRE
RISK AREA. PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL CONTACT.
KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:AVOID PROLONGED INHALATION OF VAPORS.IF VENTILATION
IS POOR,USE A FRESH AIR SUPPLY MASK.DO NOT USE H*2O STREAM ON
FIRE.H*2O SPRAY/FOG CAN BE USED EFFECTVLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR SCBA,IN FIRE, OTHERWISE NIOSH APPRVD RESPIR
Ventilation:MECH(GEN)OR LOCAL EXHAUST THAT PROVIDES ADEQUATE
VENTILATION
Other Protective Equipment:FULL WORK CLOTHING TO PREVENT REPEATED OR
PROLONGED CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.NO SMOKING NEAR THIS PRODUCT.
Supplemental Safety and Health
PRODUCT CONSISTS OF A 2-PART KIT.THIS IS OLD FORMULATION FOR BASE.FOR
NEW FORMULATION,SEE PNI C.FOR CATALYST,SEE PNI B,SAME NSN. KEY1:F3.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:169-331F
Vapor Pres:15
Vapor Density:>1.0
Spec Gravity:1.37
Evaporation Rate & Reference:<1(SLWR THAN ETHR)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:FLAT GRAY PAINT,ODOR PLEASANT-PUNGENT
Percent Volatiles by Volume:53.4
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, CORROSIVES, PEROXIDES
Stability Condition to Avoid:SHOCK,HEAT,IGNITION SOURCES
Hazardous Decomposition Products:CO*2, CO, TOXIC OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE FEDERAL,STATE AND
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EPX13 BATTERY (MERCURIC OXIDE-ZINC)
CAGE:83740
CAGE:83740
============= Composition/Information on Ingredients =============
Ingred Name:MANGANESE DIOXIDE
CAS:1313-13-9
RTECS #:OP0350000
Fraction by Wt: 0-15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG MN/M3 CEILING
ACGIH TLV:5 MG MN/M3
Ingred Name:MERCURY (SARA III)
CAS:7439-97-6
RTECS #:OV4550000
Fraction by Wt: 0.3-1.5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S, C, 0.1 MG/M3
ACGIH TLV:S, 0.05 MG/M3; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:MERCURIC OXIDE (SARA III)
CAS:21908-53-2
RTECS #:OW8750000
Fraction by Wt: 20-50%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG HG/M3;SKIN;C
ACGIH TLV:0.1 MG HG/M3; 9293
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 0-6%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C, 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 0-6%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ZINC (SARA III)
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: 5-15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG ZNO/M3
ACGIH TLV:10 MG ZNO/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPOSURE TO MERCURY-ACUTE:
SKIN:IRRITATION, ANURIA. EYE:IRRITATION, CORNEAL INJURY OR BURNS.
INGESTION:IMMEDIATE NECROSIS IN MOUTH, THROAT, ESOPHAGUS & STOMACH.
DEATH MAY OCCURE. INHALATION:DYSPNEA, C OUGH, FEVER, NAUSEA &
VOMITING, DIARRHEA, STOMATITIS, SALIVATION & METALLIC TASTE.
CHRONIC: CNS DISTURBANCES.
Explanation of Carcinogenicity:MERCURY, ZINC AND AMMONIUM CHLORIDE ARE
NOT LISTED BY IARC, NTP, OR OSHA AS CARCINOGENS.
Effects of Overexposure:TREMORS, CONVULSIONS & OTHER CNS DISTURBANCES,
PNEUMONITIS, CHEST PAINS, DYSPNEA, COUGHING, STOMATITIS, GINGIVITIS
AND LOOSENING OF TEETH, SALIVATION, LOSS OF MEMORY, METALLIC TASTE,
DIZZINESS, CLUMSI NESS, SLURRED SPEECH, DIARRHEA, PAIN & NUMBNESS
IN EXTREMITIES, NEPHRITIS, ANXIETY, HEADACHE, WEIGHT LOSS, AND
INSOMNIA.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF
ALCOHOLISM, CHRONIC KIDNEY DISEASE OR KNOWN ALLERGY TO MERCURY MAY
BE AT INCREASED RISK FROM EXPOSURE TO MERCURY IF THE BATTERY IS
RUPTURED.
======================= First Aid Measures =======================
First Aid:IF EXPOSED TO RUPTURED BATTERY-INHALATION:REMOVE TO FRESH
AIR. IF NOT BREATHING GIVE CPR/OXYGEN. GET MEDICAL ATTENTION.
EYE:IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR 15 MINUTES. GET
MEDICAL ATTE NTION. SKIN: WASH SKIN WITH PLENTY OF SOAP & WATER.
INGESTION: GET IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS AND/OR MAY CAUSE
EXPLOSION.
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP ALL BATTERIES. FOR A SMALL SPILL OF A
RUPTURED BATTERY: COLLECT THE DUST WITH A VACUUM CLEANER AND
DISPOSE OF BAG. WASH THE AREA.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA AWAY FROM HEAT. STACK CARTONS NO MORE THAN 4 LAYERS HIGH ON A
PALLET AND NO MORE THAN 3 PALLETS HIGH.
Other Precautions:DO NOT SEAL BATTERIES IN AIR TIGHT OR WATERTIGHT
CONTAINERS OR COMPARTMENTS. DO NOT RUPTURE OR THROW BATTERIES IN
FIRE. DO NOT RECHARGE BATTERIES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMALLY NOT REQUIRED. WEAR MASK WHEN HANDLING
DUST FROM RUPTURED BATTERY.
Ventilation:GENERAL/LOCAL EXHAUST VENTILATION.
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
THESE BATTERIES ARE MANUFACTURED "ARTICLES", WHICH DO NOT RESULT IN
EXPOSURE TO A HAZARDOUS CHEMICAL UNDER NORMAL CONDITIONS OF USE, AS
DEFINED IN OSHA HCS 1910.1200(C). WHEN HANDLING RUPTURED BATTERY
DO NOT GET ON SKIN, IN EYES OR ON CLOTHING. DO NOT BREATHE VAPORS.
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:CYLINDRICAL /D/
Percent Volatiles by Volume:NO
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCTS INCLUDE
TOXIC MERCURY VAPORS AND AMMONIUM CHLORIDE FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE, BURY IN LANDFILL IN
ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:U-24 LATEX
Kit Part:Y
CAGE:4Z694
CAGE:4Z694
============= Composition/Information on Ingredients =============
Ingred Name:ACRYLIC POLYMER
CAS:25068-63-7
Fraction by Wt: 36.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DEFOAMER
Fraction by Wt: 0.5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 63.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:FORMALDEHYDE (SARA 302/313) (CERCLA)
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: 0.05%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RAT LD50 >50G/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: HEADACHE, NAUSEA,
NOSE/THROAT/LUNG IRRITATION. SKIN: IRITATION. EYE: IRRITATION.
======================= First Aid Measures =======================
First Aid:INHAL: MOVE TO FRESH AIR. EYE: FLUSH W/LARGE AMOUNTS WATER
FOR >15 MINUTES, CALL DR. SKIN: WASH W/SOAP & WATER
===================== Fire Fighting Measures =====================
Flash Point:NONCOMBUSTIBLE
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:NA
Fire Fighting Procedures:NA
Unusual Fire/Explosion Hazard:MAY SPLATTER >212F POLYMER FILMS WILL
BURN.
================== Accidental Release Measures ==================
Spill Release Procedures:EVAC AREA, FLOOR MAY BE SLIPPERY. DIKE/CONTAIN
W/INERT MATERIAL, TRANSFER TO CONTAINER FOR RECOVERY/DISPOSAL, KEEP
AWAY FROM BODIES OF WATER.
Neutralizing Agent:FERRIC CHLORIDE & LIME.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BETWEEN 34 & 140F, DONT FREEZE,
MAINTAIN ADEQUATE VENTWHERE PRODUCT HEATED/CURED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED IF GOOD VENT. IF NOT, USE
MSHA/NIOSH APPROVED EQUIPMENT.
Ventilation:LOCAL EXHAUST AT POINT OF CONTAMINATION, MECHANICAL VENT AT
POINT OF CONTAMINATION RELEASE.
Other Protective Equipment:ADEQUATE SKIN PROTECTION.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:17 @ 68F
Vapor Density:350F
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH CLEAR SUPERNANT LIQUID TO CHEM SEWER.
LANDFILL/INCINERATE SOLIDS ACCORDING TO LOCAL/STATE/FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:B61 E19 KEM A & A EPOXY ENAMEL, OSHA RED
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:ISOPARAFFINIC HYDROCARBONS (NAPHTHA PETROLEUM),
HYDROTREATED HEAVY, NON AROMATIC HEAVY NAPHTHA) ISOPAR G *92-2*
CAS:64742-48-9
Fraction by Wt: 14%
Other REC Limits:300 PPM EXXON
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; PETROLEUM DISTILLATE,
HYDROTREATED
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 26%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:MEDIUM ALIPHATIC NAPHTHA (AROMATIC 100), PARAFFIN-NAPTHANES
MINERAL SPIRITS *92/2*
CAS:64742-88-7
Fraction by Wt: 4%
Other REC Limits:100 PPM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 1%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 3%
OSHA PEL:20 MPPCF
ACGIH TLV:2 MG/CUM (RESP DUST)
Ingred Name:TITANIUM DIOXIDE, TITANIUM(IV) OXIDE, TIO2
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 1%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:MOLYBDATE ORANGE; LEAD CHROMATE MOLYBDATE SULFATE RED (A1
HUMAN CARCINOGEN BY IARC)
CAS:12656-85-8
RTECS #:QA4660000
Fraction by Wt: 12%
Other REC Limits:STEL 10 MG/CUM
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:LEAD, INORGANIC LEAD (SUSPECTED HUMAN CARCINOGEN BY IARC,
NTP & ACGIH)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 12%
OSHA PEL:0.05 MG/CUM
ACGIH TLV:0.15 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CHROMIUM METAL, CHROMIUM, CHROME (SUSPECTED A1 HUMAN
CARCINOGEN BY IARC, NTP & ACGIH)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 12%
OSHA PEL:1 MG/CUM (CEILING)
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:WEIGHT PER GALLON IN POUNDS: 8.48
RTECS #:9999999WG
Ingred Name:VOL ORGANIC CMPD: 3.92
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY SYSTEM
IRRITATION, NERVOUS SYSTEM DEPRESSION, HEADACHE, DIZZINESS, NAUSEA,
LOSS OF COORDINATION, & POSSIBLY DEATH. SKIN/EYES: IRRITATION,
REDNESS, ITCHING OR BURNING SENSATION.
Explanation of Carcinogenicity:LEAD, CHROMIUM & MOLYBDATE ORGANGE ARE
SUSPECTED HUMAN CARCINOGENS BY ACGIH.
Effects of Overexposure:INHALATION: DAMAGE TO THE LIVER, URINARY,
REPRODUCTIVE, NERVOUS SYSTEMS, EMBRYOTOXIC EFFECTS, PERMANENT BRAIN
DAMAGE. SKIN/EYS: IRRITATION, REDNESS, ITCHING OR BURNING
SENSATION.
======================= First Aid Measures =======================
First Aid:INHALATION: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE
BREATHING. KEEP WARM/QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY
W/SOAP & WATER. EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS.
INGESTION: OB TAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:70F
Lower Limits:0.9%
Upper Limits:6%
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIP & SCBA. WATER SPRAY:
INEFFECTIVE. FOG NOZZLES: PREFERABLE. USE WATER TO COOL FIRE
EXPOSED CONTAINERS TO PREVENT PRESSURE BUILD-UP.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY BUILD-UP PRESSURE,
EXPLODE OR AUTOIGNITE WHEN EXPOSED TO EXTREME HEAT. APPLICATION TO
HOT SURFACES REQUIRES SPECIAL PRECAUTIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION.
VENTILATE/REMOVE W/INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT/SPARKS/OPEN FLAME.
KEEP AREA VENTILATED. EXTINGUISH FLAMES/PILOT LIGHTS/HEATERS. TURN
OFF STOVES/ELECTRIC TOOLS/APPLIANCES.
Other Precautions:CONSULT NFPA CODE. USE APPROVED BONDING/GROUNDING
PROCEDURES. KEEP CONTAINERS CLOSED WHEN NOT IN USE. TRANSFER ONLY
TO APPROVED CONTAINERS. DON'T TAKE INTERNALLY. KEEP OUT OF REACH OF
CHILDREN. AVOID CONTACT W/SKIN/EYES & BREATHING VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH/MSHA APPROVED PROPERLY FITTED
ORGANIC VAPOR/PARTICULATE RESPIRATOR. USE A NIOSH/MSHA APRPOVED
DUST/MIST RESPIRATOR WHEN SANDING OR ABRADING THE DRIED FILM.
Ventilation:LOCAL EXHAUST: PREFERABLE. GENERAL EXHAUST: ACCEPTABLE
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS AFTER USING.
Supplemental Safety and Health
BOILING RANGE: 240-416F. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING & INHALING CONTENTS CAN BE HARMFUL/FATAL. DON'T APPLY
ON TOYS/CHILDREN'S ARTICLES/FURNITURE/ANY INTERIOR/EXTERIOR OF A
DWELLIN G WHICH MAY BE OCCUPIED OR USED BY CHILDREN.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:SEE SUPP
Vapor Density:>AIR
Spec Gravity:0.91-1.26
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:61-66%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME OR OTHERS SOURCES
OF IGNTION
Hazardous Decomposition Products:CO2, CO, OXIDE OF METALS IN THE
INGREDIENTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MAY BE HAZARDOUS AS DEFINED UNDER THE
RCRA/TEST FOR IGNITABILITY. INCINERATE IN APPROVED FACILITY. DON'T
INCINERATE CLOSED CONTAINER. DISPOSE OF IN ACCORDANCE WITH FEDERAL,
STATE, & LOCAL REGULA TIONS REGARDING POLLUTION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:VINYLUX WHITE BASE, 012 001
Preparer's Name:ZEKE
CAGE:FO493
CAGE:1GK99
CAGE:FO493
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL; VP:0.1 MM/HG @ 68F (SARA III)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 1%
OSHA PEL:N/K
ACGIH TLV:C 50 PPM,VAPOR
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:COATING VOLATILE ORGANIC COMPOUND:0.80 LB/GL (96 G/L)
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MATERIAL VOLATILE ORGANIC COMPOUND:0.30 LB/GL (36 G/L).
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:VAPOR OR MIST CAN CAUSE
HEADACHE, NAUSEA AND IRRITATION OF THE NOSE, THROAT AND LUNGS. SKIN
CONT:USE GOOD PERSONAL HYGIENE PRACTICES WHILE WORKING WITH THIS
MATERIAL. DRY CONTAMINATED CLOTHING B EFORE REUSE. EYE:FLUSH WITH
FRESH WATERFOR AT LEAST 15 MINUTES. IF IRRITATION PERSISTS, GET
MEDICAL (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:ATTN. SKIN ABSORPTION:NONE EXPECTED.
INGEST:MAY BE HARMFUL IF SWALLOWED. INGESTION MAY CAUSE NAUSEA,
VOMITING, DIARRHEA, AND GASTROINTESTINAL IRRITATION. CONSULT A
PHYSICIAN. ACUTE/CHRONIC H AZS:NONE EXPECTED.
Medical Cond Aggravated by Exposure:OVEREXPOSURE TO VAPORS CAN CAUSE
HEADACHES, DIZZINESS AND NAUSEA.
======================= First Aid Measures =======================
First Aid:SKIN:CLEAN WITH SOAP AND WATER. INGEST:CONSULT A PHYSICIAN.
INHAL:REMOVE TO FRESH AIR. EYE:FLUSH WITH WATER FOR AT LEAST 15
MINUTES. CONSULT A PHYSICIAN.
===================== Fire Fighting Measures =====================
Lower Limits:3.2%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:FOLLOW RECOMMENDED PROCEDURES IN HANDLING FIRE
AREAS. WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:POLYMER FILM CAN BURN. MATERIAL CAN
SPLATTER ABOVE 212F.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP IMMEDIATELY AND SAFELY DISCARD
ABSORBENTS. IN THE EVENT OF LARGE SPILLS, DIKE THE AREA AND PUMP
THE MATERIAL TO AN EPA PERMITTED WASTE TANK.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION. AVOID
PROLONGED BREATHING OF VAPOR. AVOID PROLONGED OR REPEATED SKIN
CONTACT. KEEP AWAY FROM EXCESSIVE HEAT.
Other Precautions:AVOID ALL SOURCES OF HEAT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN SPRAYING MATL USE NIOSH/MSHA APPRVD
CARTRIDGE RESP/GAS MASK SUITABLE TO KEEP AIRBORNE MISTS & VAP CONCS
BELOW TIME WEIGHTED TLV. WHEN USING IN POORLY VENT & CONFINED
SPACES USE NIOSH/MSHA APPRVD FRESH-AIR SUPPLYING RESP OR SCBA.
Ventilation:MAINTAIN GOOD VENTILATION TO KEEP PRODUCT VAPOR
CONCENTRATIONS BELOW SPECIFIED TLV VALUES.
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING AND BOOTS.
Work Hygienic Practices:EYE WASHES & SAFETY SHOWERS IN WORKPLACE ARE
RECOMMENDED, AS WELL AS BARRIER CREAMS, DAILY SHOWERS & CHANGE OF
CLOTHES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:SEE INGS
Vapor Density:LTR/AIR
Spec Gravity:1.5 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:DILUTABLE
Appearance and Odor:WHITE VISCOUS LIQUID. MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID MATERIALS THAT ARE WATER REACTIVE. ALSO AVOID STRONG ALKALINE AND
ACIDIC SUBSTANCES.
Stability Condition to Avoid:EXCESS HEAT MAY CAUSE CONTAINERS TO
RUPTURE. AVOID TEMPERATURES BELOW 40F. AVOID FREEZING CONDITIONS.
Hazardous Decomposition Products:CO, CO*2 ON COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS CURRENTLY IN FORCE FOR THIS PRODUCT HAZARD
CLASS.
| 1 | gloves_mandatory |
=======================================================
Product ID: 3732 BLUE, THE FRESH LOOK FAST DRYING (SUPDAT)
Cage: IO494
Box: 6709
=======================================================
Contractor Summary
=======================================================
Cage: 59019
Box: 6709
Cage: IO494
Box: 6709
=======================================================
Ingredients
=======================================================
Cas: 74-98-6
RTECS #: TX2275000
% Wt: 14
OSHA PEL: 1000 PPM
ACGIH TLV: ASPHYXIANT
------------------------------
Cas: 106-97-8
RTECS #: EJ4200000
% Wt: 13
OSHA PEL: 800 PPM
ACGIH TLV: 800 PPM
------------------------------
Cas: 100-41-4
RTECS #: DA0700000
% Wt: 4
OSHA PEL: 100 PPM
ACGIH TLV: 100 PPM; 125 STEL
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 1330-20-7
RTECS #: ZE2100000
% Wt: 20
OSHA PEL: 100 PPM
ACGIH TLV: 100 PPM; 150 STEL
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 67-64-1
RTECS #: AL3150000
% Wt: 34
OSHA PEL: 1000 PPM
ACGIH TLV: 750 PPM; 1000 STEL
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 13463-67-7
RTECS #: XR2275000
% Wt: 1
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST
------------------------------
RTECS #: 9999999VO
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
- EXTING ALL FLAMES, PILOT LIGHTS &
-----------------------------
ANY OTHER SOURCES OF IGNIT. CONSULT NFPA CODE.
-----------------------------
NOT PUNCTURE, INCIN OR EXPOSE TO TEMP
-----------------------------
& OTHER HEAT SOURCES COULD CAUSE CNTNR TO
-----------------------------
-----------------------------
INGRED SECTION) WHICH MAY BE PRESENT AT
-----------------------------
SPECIFIC DUSTS ARE LISTED, APPLIC LIMS
-----------------------------
(RESPIRABLE DUST), OSHA PEL 15 MG/M3
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: IRRIT OF EYES, SKIN & RESP SYS. MAY CAUSE
NERVOUS SYS DEPRESS. EXTREME OVEREXP MAY RSLT IN UNCON & POSS DEATH.
HDCH, DIZZ, NAUS & LOSS OF COORD ARE INDICATIONS OF EXCESSIVE EXPOS TO
VAPS/SPRAY MIST. REDNESS & ITCH OR BURNING SENSATION MAY INDICATE
EYE/EXCESSIVE SKIN EXPOS. CHRONIC: PRLNGD (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ: OVEREXP TO SOLV INGREDS LISTED
MAY CAUSE ADVERSE EFTS TO LIVER, URINARY, BLOOD-FORMING, CARDIOVASCULAR &
REPRO SYS. RATS EXPOS TO TITANIUM DIOXIDE DUST AT 250 MG/M3 DEVELOPED LUNG
CANCER, HO WEVER, SUCH EXPOS LEVELS ARE NOT ATTAINABLE IN WORKPLACE. RPTS
HAVE ASSOC RPTD & PRLNGD OVEREXP TO SOLVS W/PERM (SUPDAT)
Medical Cond Aggravated By Exposure: NONE GENERALLY RECOGNIZED.
First Aid: INHAL: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP
WARM & QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY W/SOAP & WATER.
REMOVE CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE. EYES: FLUSH EYE S
W/LARGE AMOUNTS OF WATER FOR AT LEAST15 MINUTES. GET MED ATTN. INGEST: NEVER
GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. DO NOT INDUCE VOMITING. GIVE
SEVERAL GLASSES OF WATER. SEEK MED ATTN.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION. VENTILATE AND REMOVE
WITH INERT ABSORBENT.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: WASTE FROM THESE PRODS MAY BE HAZ AS DEFINED UNDER RCRA
40 CFR 261. WASTE MUST BE TESTED FOR IGNITABILITY TO DETERMINE APPLIC EPA HAZ
WASTE NUMBERS. DO NOT INCIN. DEPRESSURIZE CNTNR. DISPOSE OF I/A/W FEDERAL,
STATE & LOCAL REGS REGARDING POLLUTION.
Handling And Storage Precautions: CONTENTS ARE EXTREMELY FLAMMABLE. KEEP AWAY
FROM HEAT, SPKS & OPEN FLAME. VAPS WILL ACCUM READILY & MAY IGNITE
EXPLOSIVELY. DURING USE &
Other Precautions: INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING &
INHALING CONTENTS CAN BE HARMFUL/FATAL. USE ONLY W/ADEQ VENT. AVOID BRTHG VAP
& SPRAY MIST. AVOID CONTACT W/SKIN & EYES. WASH HANDS AFTER USING.
THES E COATINGS MAY CONTAIN MATLS
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point Text: <0F,<-18C
Lower Limits: 0.7%
Upper Limits: 12.8%
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: USE NIOSH APPRVD SCBA & FULL PROT EQUIP (FP N).
WATER SPRAY MAY BE INEFTIVE. IF WATER IS USED, FOG NOZZS ARE PREF. WATER MAY
BE USED TO COOL CLSD (SUPDAT)
Unusual Fire/Explosion Hazard: CLOSED CONTAINERS MAY EXPLODE (DUE TO THE
BUILD-UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW APPLIC
LIMS BY VENT, WEAR NIOSH APPRVD, PROPERLY FITTED ORG VAP/PARTICULATE RESP.
WHEN SANDING OR ABRADING DRIED FILM, WEAR DUST/MIST RESP APPRVD BY NIOSH FOR
PROT AGAINST NON-VOLAT MATLS LISTED.
Ventilation: LOC EXHST PREF. GEN EXHST ACCEPTABLE IF EXPOS IS MAINTAINED BELOW
APPLIC LIMS. REFER TO OSHA STDS 1910.94, 107, 108.
Other Protective Equipment: ANSI APPROVED EYE WASH & DELUGE SHOWER (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: MFR'S TRADE NAME/PART NO: SPRAY ENAMELS. FIRE
FIGHT PROC: CNTNRS TO PVNT PRESS BUILD-UP & POSS AUTOIGNIT OR EXPLO WHEN
EXPOSED TO EXTREME HEAT. EFTS OF OVEREXP: BRAIN & NERVOUS SYS DMG. THESE
PRODS CO NTAIN CHEMS KNOWN TO STATE OF CA TO CAUSE CANCER & BIRTH DEFECTS
OR OTHER REPRO HARM.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: <600F,<316C
Vapor Pres: SEE INGS
Vapor Density: HVR/AIR
Evaporation Rate & Reference: FASTER THAN ETHER
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume: >75
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE KNOWN.
Materials To Avoid: NONE KNOWN.
Hazardous Decomposition Products: BY FIRE: CARBON DIOXIDE, CARBON MONOXIDE,
OXIDES OF METALS LISTED IN INGREDIENT SECTION.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: 3732 BLUE, THE FRESH LOOK FAST DRYING (SUPDAT)
Cage: IO494
Assigned IND: Y
Company Name: DUTCH BOY GROUP
Street: 101 PROSPECT AVE NW
PO Box: 6709
Zipcode: 44101
Label Required IND: Y
Date Of Label Review: 07/07/1998
Status Code: C
Label Date: 07/07/1998
Origination
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: EXTREMELY FLAMMABLE. ACUTE: IRRITATION OF EYES, SKIN
AND RESPIRATORY SYSTEM. MAY CAUSE NERVOUS SYSTEM DEPRESSION. MAY RESULT IN
HEADACHE, DIZZINESS, NAUSEA, LOSS OF COORDINATION, UNCONSCIOUSNESS AND D
EATH. REDNESS AND ITCHING OR BURNING SENSATION MAY INDICATE EYE OR EXCESSIVE
SKIN EXPOSURE. CHRONIC: PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE ADVERSE
EFFECTS TO LIVER, URINARY, BLOOD-FORMING, CARD IOVASCULAR AND REPRODUCTIVE
SYSTEMS AND HAS BEEN ASSOCIATED WITH PERMANENT BRAIN AND NERVOUS SYSTEM
DAMAGE.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RED CELL TAGGING KIT (SODIUM CHROMATE CR51)
CAGE:ZA916
CAGE:2A916
CAGE:ZA916
============= Composition/Information on Ingredients =============
Ingred Name:RADIOACTIVE CHROMIUM; (SODIUM CHROMATE CR-51) (COMPONENT OF
SODIUM CHROMATE CR 51 INJECTION)
CAS:10039-53-9
< Wt:0.
Ingred Name:SODIUM BICARBONATE (COMPONENT OF SODIUM CHROMATE CR 51
INJECTION)
CAS:144-55-8
RTECS #:VZ0950000
= Wt:.05
Ingred Name:WATER (COMPONENT OF SODIUM CHROMATE CR 51 INJECTION AT
ABOUT 100%; COMPONENT OF A-C-D SOLUTION AT 96%)
CAS:7732-18-5
RTECS #:ZC0110000
Minumum % Wt:96.
Maxumum % Wt:100.
Ingred Name:CITRIC ACID (COMPONENT OF A-C-D SOLUTION)
CAS:77-92-9
RTECS #:GE7350000
< Wt:1.
Ingred Name:DEXTROSE ANHYDROUS (COMPONENT OF A-C-D SOLUTION)
CAS:50-99-7
RTECS #:LZ6600000
= Wt:1.1
Ingred Name:TRISODIUM CITRATE; (SODIUM CITRATE) (COMPONENT OF A-C-D
SOLUTION)
CAS:68-04-2
RTECS #:GE8300000
= Wt:2.3
Ingred Name:ASCORBIC ACID
CAS:50-81-7
RTECS #:CI7650000
= Wt:10.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THE FOLLOWING INFORMATION REFERS TO
RADIOACTIVE MATERIAL. ACUTE: INHALATION: SODIUM CHROMATE DOES NOT
EASILY BECOME AIRBORNE. NOT EXPECTED TO BE A HEALTH HAZARD VIA
INHALATION. INGESTION: MAY CAUSE AS YMPTOMATIC PHYSIOLOGICAL UPTAKE
BY SPECIFIC TARGET ORGANS OR TISSUES. SKIN: NOT EXPECTED TO PRODUCE
ANY ACUTE ADVERSE HEALTH EFFECTS. EYES:NO ADVERSE EFFECT EXPECTED,
BUT MAY CAUSE MECHANICAL IRRITATI ON. CHRONIC: THE HEALTH RISKS
ASSOCIATED WITH CHRONIC RADIATION EXPOSURE (CANCER, LEUKEMIA,
GENETIC AND TERATOGENIC EFFECTS) ARE BELIEVED TO INVOLVE LEVELS OF
RADIATION EXPOSURE WHICH ARE MUCH HIGHER THAN THOSE PERMITTED
OCCUPATIONALLY.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NO INFORMATION FOUND.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
OXYGEN OR ARTIFICIAL RESPIRATION) . INGESTION: NOTIFY RADIATION
SAFETY PERSONNEL IMMEDIATELY. AMOUNT OF MATERIAL INGESTED SHOULD BE
ASSES SED AND DOCUMENTED. SKIN: WASH AFFECTED AREA THOROUGHLY WITH
SOAP AND WATER UNTIL NO MORE RADIOACTIVITY CAN BE REMOVED. ALWAYS
BLOT DRY. DO NOT ABRADE SKIN. NOTIFY RADIATION SAFETY PERSONNEL.
EYES: WA SH WITH WATER FOR AT LEAST 15 MINUTES OR UNTIL NO MORE
RADIOACTIVITY CAN BE REMOVED. NOTIFY RADIATION SAFETY PERSONNEL.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE ANY MEANS SUITABLE FOR EXTINGUISHING
SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:FLAMMABILITY: NOT A FLAMMABLE MATERIAL.
NOT CONSIDERED TO BE A FIRE OR EXPLOSION HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:IF THE PRODUCT IS RECEIVED IN A LEAKING
CONDITION OR ANY LOSS OR RELEASE OF RADIOACTIVE CONTENTS OCCURS,
NOTIFY YOUR RADIATION SAFETY DEPARTMENT AND MFR AT (314) 770-7800.
ALL CLEANUP OPERATIONS SHOU LD BE PERFORMED ACCORDING TO THE
STANDARD OPERATING PROCEDURES (SOPS) ESTABLISHED FOR YOUR FACILITY
AND BY THE NRC OR OTHER APPLICABLE LOCAL, STATE OR FEDERAL
REGULATIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE @ 15-30C. HNDLG TIME SHOULD BE
KEPT TO MIN & APPROP SHIELDING SHOULD BE USED. HNDLG DEVICES SUCH
AS SYRINGE SHIELDS & TONGS SHOULD BE USED. STOR & DISP OF PROD
SHOULD BE CONTROLLED IN MANNER WHI CH IS IN COMPLIANCE W/APPROP
REGS OF FED/STATE GOVT AGENCY AUTH TO LICENSE USE OF THIS
RADIONUCLIDE.
Other Precautions:CAUTION! RADIOACTIVE MATL. READ PACKAGE INSERT PRIOR
TO USE. PROMPTLY REMOVE ANY CONTAM FROM SKIN, EYES/CLTHG.
RADIOACTIVE DRUGS MUST BE HNDLD BY QUALIFIED PERS IN CONFORMITY
W/REGS APPROP TO GOVT AGE NCY AUTH TO LICENSE USE OF THIS
RADIONUCLIDE. VIAL CNTNG DRUG SHOULD BE KEPT W/IN ITS CNTNR/WITHIN
H EAVIER (SUPP DATA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NOT EXPECTED TO REQUIRE PERSONAL RESPIRATOR
USAGE.
Ventilation:PROPERLY SEALED CONTAINERS ARE NOT EXPECTED TO REQUIRE ANY
SPECIAL VENTILATION.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
LABCOAT.
Work Hygienic Practices:NO SMOKING, EATING OR DRINKING SHOULD BE
ALLOWED IN ANY AREA WHERE RADIOACTIVE MATERIALS ARE HANDLED OR
STORED.
Supplemental Safety and Health
OTHER PREC: SHEILDING. AVOID CONT W/RADIOACTIVE CONTENTS WHICH WOULD
CAUSE UNNEC EXPOS TO RADIATION. WASTE DISP METH:ACCORDINGLY. IF NOT
RADIOACTIVE OR BIOHAZARD, WASTE RED CELL TAGGING KIT (SODIUM CH
ROMATE CR 51) IS CONSIDERED NON-HAZ. CONSULT LOC, STATE & FED REGS
FOR PROPER DISP. RCRA HAZ WASTE STATUS: NON-HAZ.
================== Physical/Chemical Properties ==================
Boiling Pt:=100.C, 212.F
Melt/Freeze Pt:=0.C, 32.F
Vapor Pres:NO INFO FOUND
Vapor Density:N/I
Evaporation Rate & Reference:NO INFORMATION FOUND
Solubility in Water:SOLUBLE
Appearance and Odor:SODIUM CHROMATE CR 51:CLEAR, COLORLESS LIQ IN 10 ML
GLASS VIAL; (OTHER INFO)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NO INFORMATION FOUND.
Stability Condition to Avoid:STABLE UNDER ORDINARY CONDITIONS OF USE
AND STORAGE.
Hazardous Decomposition Products:MAY EMIT RADIOACTIVE FUMES CONTAINING
CR 51 WHEN HEATED TO DECOMPOSITION.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:IT IS WIDELY ACCEPTED BY THE SCIENTIFIC
COMMUNITY THAT EXPOSURE TO SUFFICIENT QUANTITIES OF IONIZING
RADIATION CAN POTENTIALLY CAUSE HARMFUL BIOLOGICAL EFFECTS WHICH
INCLUDE CANCER, LEUKEMIA, AND GENE TIC AND TERATOGENIC EFFECTS. FOR
DETAILED TOXICOLOGICAL INFORMATION ON SPECIFIC COMPONENTS, WRITE TO
THE ADDRESS LISTED IN SECTION 1 - ATTN: REGULATORY COMPLIANCE
DEPARTMENT.
===================== Ecological Information =====================
Ecological:BECAUSE THIS PRODUCT IS INTENDED FOR USE BY HOSPITAL OR
CLINIC PATIENTS, IT IS EXPECTED TO BE TREATED BY STANDARD
WASTEWATER TREATMENT FACILITIES WITH NO ADVERSE ENVIRONMENTAL
IMPACTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:RED CELL TAGGING KIT (SODIUM CHROMATE CF 51) IS
RADIOACTIVE WASTE UNTIL ACTIVITY HAS DECAYED TO NONDECTABLE LEVELS.
RADIOACTIVE WASTE MUST BE HNDLD II/A/W PROCS ESTABLISHED BY YOUR
RADIA SFTY OFFICER, NRC & OTHER APPLIC REGS. IF MED WASTE IS
INVOLVED, SUCH AS BLOOD, BLOOD PROD/SHARPS, WASTE MUST BE HNDLD AS
BIOHAZARD & DISPOSED OF (SUPP DATA)
=================== MSDS Transport Information ===================
Transport Information:DOT (DEPARTMENT OF TRANSPORTATION): PROPER
SHIPPING NAME: RADIOACTIVE MATERIAL, EXCEPTED PACKAGE - LIMITED
QUANTITY OF MATERIAL. HAZARD CLASS: 7. IDENTIFICATION NUMBER:
UN2910.
===================== Regulatory Information =====================
SARA Title III Information:302 EXTREMELY HAZARDOUS SUBSTANCES: NONE.
311/312 HAZARD CATEGORIES: CHRONIC. 313 TOXIC SUBSTANCES SUBJECT TO
ANNUAL RELEASE REPORTING REQUIREMENTS: CHROMIUM COMPOUNDS.
Federal Regulatory Information:OSHA HAZARD COMMUNICATION: THIS PRODUCT
IS CONSIDERED HAZARDOUS UNDER OSHA HAZARD COMMUNICATION STANDARD
(29 CFR 1910.1200). CERCLA REPORTABLE QUANTITIES: CR 51 = 1000 CI
(3.7 E 13 BQ). RELEASES TO AI R, LAND OR WATER OF THESE HAZARDOUS
SUBSTANCES WHICH EXCEED REPORTABLE QUANTITY (RQ) MUST BE REPORTED
TO THE NATIONAL RESPONSE CENTER AT 800-424-8802.
State Regulatory Information:CALIFORNIA PROPOSITION 65 WARNING: THIS
PRODUCT CONTAINS A SUBSTANCE KNOWN TO THE STATE OF CALIFORNIA TO
CAUSE CANCER.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:KODAK EKTACOLOR RA BLEACH FIX AND REPLENISHER NR, PART A
Kit Part:Y
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIUM THIOSULFATE
CAS:7783-18-8
RTECS #:XN6465000
Fraction by Wt: 50-55%
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 35-45%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM BISULFITE
CAS:7631-90-5
RTECS #:VZ2000000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:AMMONIUM SULFITE
CAS:10196-04-0
RTECS #:WT3505000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:AMMONIUM BISULFITE
CAS:10192-30-0
RTECS #:WT3595000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS UNKNOWN.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION-EXPECT TO BE A LOW HAZARD
FOR RECOMMENDED HANDLING. EYES-NO SPCEIFIC HAZARD KNOWN. MAY CAUSE
TRANSIENT IRRITATION. SKIN-LOW HAZARD FOR RECOMMENDED HANDLING.
INGESTION-EXPECTED TO BE A LOW I NGESTION HAZARD.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION-IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL AID
IF SYMPTOMS PERSISTS. EYES-ANY MATERIAL THAT CONTACT THE EYE SHOULD
BE WASHED OUT IMMEDIATELY WITH WATER. GET MEDICAL AID IF SYMPTOMS
OCCU R. SKIN-WASH WITH SOAP & WATER. GET MEDICAL AID IF SYMPTOMS
OCCUR. INGESTION-DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL AID.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE APPROPIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER.
OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT MATERIAL,
THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. KEEP
AWAY FROM INCOMPATIBLE SUBSTANCES.
Other Precautions:USE ONLY WITH ADEQUATE VENTILATION. WASH THOROUGHLY
AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION (10 AIR CHANGES PER HOUR) SHOULD
BE USED. VENTILATION RATES SHOULD MATCH TO CONDITIONS.
CLOTHING APPROPIATE FOR THE RISK OF EXPOSURE. EYE BATH, SAFETY
SHOWER.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
KEY 1: N1. THIS ITEM IS PART OF A THREE PART KIT. THIS IS PART A.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:18 MMHG
Vapor Density:O.6
Spec Gravity:1.34
pH:5.8
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID, COLORLESS, AMMONIA ODOR.
Percent Volatiles by Volume:50-55
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, BASES, ACIDS, SODIUM HYPOCHLORITE. CONTACT
WITH BASES LIBERATES FLAMMABLE MATERIALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:AMMONIA CHLORAMINE, SULFUR DIOXIDE,
NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE OR LOCAL LAWS. FLUSH TO SEWER WITH LARGE AMOUNT
OF WATER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:91902 BABY BLUE VOC COMPLIANT INDUSTRIAL (SUPDAT)
CAGE:IO479
CAGE:IO479
CAGE:09800
============= Composition/Information on Ingredients =============
Ingred Name:PROPANE; (PROPELLANT). VP: 780.0
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 13%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9495
Ingred Name:PROPANE, 2-METHYL-; (2-METHYLPROPANE (PROPELLANT)) VP:
780.0
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 13%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BENZENE, ETHYL-; (ETHYLBENZENE) (SARA 313). VP: 7.1
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 1%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/125STEL;9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE (SARA 313) (CERCLA). VP: 5.9
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 16%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE (SARA 313) (CERCLA). VP: 180.0
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 19%
OSHA PEL:1000 PPM
ACGIH TLV:750PPM/1000STEL;9495
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE) (MEK) (SARA 313)
(CERCLA). VP: 70.0
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 2%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM/300STEL;9495
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:BARIUM SULFATE
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: 13%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9495
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 6%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9495
Ingred Name:VOLATILE ORGANIC CONTENT AS A PERCENT BY WEIGHT PER BAAQMD
RULE 49: 64
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:EFTS OF OVEREXP:SOLVS. RATS EXPOSED TO TITANIUM DIOXIDE
DUST AT 250 MG/M3 DEVELOPED LUNG CANCER, HOWEVER, SUCH (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:EXPOS LEVELS ARE NOT ATTAINABLE IN WORKPLACE. RPTS
HAVE ASSOC RPTD & PRLNG OVEREXP TO SOLV W/PERMANENT (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:BRAIN AND NERVOUS SYSTEM DAMAGE.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH:REQUIRE TESTING FOR EXTRACTABILITY. DO NOT
INCINERATE. DEPRESSURIZE CONTAINER. DISPOSE OF IN (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:ACCORDANCE WITH FEDERAL, STATE, AND LOCAL
REGULATIONS REGARDING POLLUTION.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:INCINERATE, OR EXPOSE TO TEMP ABOVE 120F. HEAT
FROM SUNLIGHT, RADIATORS, STOVES, HOT WATER, & OTHER (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:HEAT SOURCES COULD CAUSE CONTAINER TO BURST. DO NOT
TAKE INTERNALLY. KEEP OUT OF THE REACH OF CHILDREN. (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND
INHALING THE CONTENTS CAN BE HARMFUL OR FATAL. (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:USE ONLY WITH ADEQUATE VENT. AVOID BREATHING VAPOR
AND SPRAY MIST. AVOID CONTACT WITH SKIN AND EYES. (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:THIS COATING MAY CONTAIN MATRL CLASSIFIED AS
NUISANCE PARTICULATES (LISTED AS DUST IN ING SECTION) WHICH(ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19:MAY BE PRESENT AT HAZ LEVELS ONLY DURING
SANDING/ABRADING OF THE DRIED FILM. IF NO SPECIFIC DUSTS ARE (ING
21)
RTECS #:9999999ZZ
Ingred Name:ING 20: LISTED IN ING SECTION, THE APPLICABLE LIMITS FOR
NUISANCE DUSTS ARE ACGIH TLV 10 MG/M3 (TOTAL DUST), (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21:OSHA PEL 15 MG/M3 (TOTAL DUST), 5 MG/M3 (RESPIRABLE
FRACTION).
RTECS #:9999999ZZ
Ingred Name:RESP PROT:RESPIRATOR APPRVD BY NIOSH/MSHA FOR DUST WHICH
MAY BE GENERATED FROM THIS PRODUCT, UNDERLYING PAINT/ABRASIVE.
RTECS #:9999999ZZ
Ingred Name:VENT:REFER TO OSHA STANDARDS 1910.94, 1910.107, 1910.108.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATION OF EYES, SKIN AND
RESPIRATORY SYSTEM. MAY CAUSE NERVOUS SYSTEM DEPRESSION. EXTREME
OVEREXPOSURE MAY RESULT IN UNCONSCIOUSNESS AND POSSIBLY DEATH.
SIGNS AND SYMPTOMS OF OVEREXPOSURE:HE ADACHE, DIZZINESS, NAUSEA,
AND LOSS OF COORDINATION ARE INDICATIONS OF EXCESSIVE EXPOSURE TO
VAPORS OR (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:SPRAY MISTS. REDNESS & ITCHING/BURNING
SENSATION MAY INDICATE EYE/EXCESSIVE SKIN EXPOSURE. CHRONIC:PRLNGD
OVEREXPOS TO SOLV INGRED IN INGRED SECTION MAY CAUSE ADVERSE EFTS
TOLIVER, URINARY, BLOOD FORMING, CARDIO-VASCULAR, & REPRO SYS.
METHYL ETHYL KETONE MAY INCREASE THE NERVOUS SYS EFFECTS OF OTHER
(ING 10)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHALED: IF AFFECTED, REMOVE FROM EXPOSURE, RESTORE
BREATHING. KEEP WARM AND QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY
WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER
BEFORE RE-USE. EYE : FLUSH WITH LARGE AMOUNTS OF WATER FORAT LEAST
15 MINUTES. GET MEDICAL ATTENTION. INGEST: GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:<0F,<-18C
Lower Limits:0.9%
Upper Limits:12.8%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
H*2O SPRAY MAY BE INEFFECTIVE. IF H*2O IS USED, FOG NOZZLES ARE
PREFERABLE. H*2O MAY BE USED TO (SUPDAT)
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT, ELEC EQUIP, SPARKS, &
OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
APPLICATION TO HOT SURFACES REQS SPECIAL (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS, & OPEN
FLAME. VAPS WILL ACCUM READILY & MAY IGNITE EXPLOSIVELY. DURING USE
& UNTIL ALL VAPS ARE GONE KEEP AREA VENT.
Other Precautions:DO NOT SMOKE. EXTING ALL FLAMES, PILOT LIGHTS, &
HEATERS. TURN OFF STOVES, ELECTRIC TOOLS & APPLIANCES, & ANY OTHER
SOURCES OF IGNIT. CONSULT NFPA CODE. USE APPRVD BONDING & GROUNDING
PROCS. CONTENTS UNDER PRESS. DO NOT PUNCTURE, (ING 15)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERS EXPOS CANNOT BE CONTROLLED BELOW APPLIC
LIMS BY VENT, WEAR PROPERLY FITTED ORG VAP/PARTICULATE RESP APPRVD
BY NIOSH/MSHA FOR PROT AGAINST MATLS IN ING SECTION. WHEN
SANDING/ABRADING THE DRIEDFILM, WEAR A DUST/MIST (ING 23)
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPTABLE IF EXPOS TO MATLS IN
ING SECTION IS MAINTAINED BELOW APPLIC EXPOS LIMITS.(ING 24)
Other Protective Equipment:ANSI APPRVD EMER EYE WASH & DELUGE SHOWER .
WEAR SAFETY SPECTACLES WITH UNPERFORATED SIDESHIELDS.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
MFR'S TRADE NAME/PART #:MAINTENANCE COLORS-3. FIRE FIGHT PROC:COOL CLSD
CNTNRS TO PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN EXPOSED
TO EXTREME HEAT. EXPLO HAZ:PRECS. DURING EMER CONDTN OVEREXP T O
DECOMP PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE IMMED APPARENT.
OBTAIN MED ATTEN.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:<0F,<-18C
Vapor Pres:SEE ING
Vapor Density:HVR/AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:>65
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF METALS IN INGREDIENT SECTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THIS PROD MAY BE HAZ AS DEFINED UNDER
RESOURCE CONSERVATION & RECOVERY ACT (RCRA) 40 CFR 261. WASTE MUST
BE TESTED FOR IGNITABILITY TO DETERMINE APPLICABLE EPA HAZ WASTE
NUMBERS. WASTE FROM PRODS CONTAINING METHYL ETHYL KETONE MAY (ING
13)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CARBOWAX PEG 8000, 15510 005
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:POLY(OXY-1,2-ETHANEDIYL), .ALPHA.-HYDRO-.OMEGA.-HYDROXY-
EINECS/ELINCS: UNLISTED.
CAS:25322-68-3
RTECS #:TQ3500000
Fraction by Wt: 100%
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL,RAT)28 GM/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: MAY CAUSE MILD EYE
IRRITATION. SKIN: LOW HAZARD FOR USUAL INDUSTRIAL HANDLING.
INGESTION: MAY CAUSE GASTROINTESTINAL IRRITATION WITH NAUSEA,
VOMITING AND DIARRHEA. INHALATION: NO HAZARD EX PECTED IN NORMAL
INDUSTRIAL USE. CHRONIC: PROLONGED OR REPEATED SKIN CONTACT MAY
CAUSE DERMATITIS. TARGET ORGANS: NONE.
Explanation of Carcinogenicity:CAS# 25322-68-3: NOT LISTED BY ACGIH,
IARC, NIOSH, NTP, OR OSHA.
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LST 15
MINS, OCCASIONALLY LIFTING UPPER & LOWER LIDS. GET MED AID. SKIN:
FLUSH WITH PLENTY OF SOAP AND WATER FOR AT LST 15 MINS WHILE
REMOVING CONTA MD CLOTHING & SHOES. GET MED AID IF IRRIT DEVELOPS
OR PERSISTS. INGEST: IF VICTIM IS CONSCIOUS & ALERT, GIVE 2-4
CUPFULS OF MILK OR WATER. NEVER GIVE ANYTHING BY MOUTH TO
UNCONSCIOUS PERSON. GET MED A ID. INHAL: REMOVE FROM EXPOSURE TO
FRESH AIR IMMED. IF NOT BRTHG, GIVE ARTF RESP. IF BRTHG IS DFCLT,
GIVE OXYGEN. GET MED AID. NOTES TO PHYS: TREAT SYMPTOMATICALLY &
SUPPORTIVELY.
===================== Fire Fighting Measures =====================
Flash Point:=268.C, 514.4F
Extinguishing Media:IN CASE OF FIRE, USE WATER, DRY CHEMICAL, CHEMICAL
FOAM, OR ALCOHOL-RESISTANT FOAM.
Fire Fighting Procedures:AS IN ANY FIRE, WEAR A SELF-CONTAINED
BREATHING APPARATUS IN PRESSURE-DEMAND, NIOSH (APPROVED OR
EQUIVALENT), AND FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:DUSTS A SUFFICIENT CONCENTRATIONS CAN
FORM EXPLOSIVE MIXTURES WITH AIR. DURING A FIRE, IRRITATING AND
HIGHLY TOXIC GASES MAY BE GENERATED BY THERMAL DECOMPOSITION OF
COMBUSTION.
================== Accidental Release Measures ==================
Spill Release Procedures:GENERAL INFORMATION: USE PROPER PERSONAL
PROTECTIVE EQUIPMENT AS INDICATED IN EXPOSURE CONTROLS, PERSONAL
PROTECTION (SECTION 8). SPILLS/LEAKS: SWEEP UP OR ABSORB MATERIAL,
THEN PLACE INTO A SUITABLECLEAN, DRY, CLOSED CONTAINER FOR
DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:CAUTION! THIS IS EXPECTED TO BE A LOW
HAZARD FOR USUAL INDUSTRIAL HANDLING. MAY CAUSE IRRITATION. USE
WITH ADEQUATE VENTILATION.
Other Precautions:STORE IN A COOL, DRY PLACE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
29 CFR 1910.134 OR EUROPEAN STANDARD EN 149. ALWAYS USE A NIOSH OR
EUROPEAN STANDARD EN 149 APPROVED RESPIRATOR WHEN NECESSARY.
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT TO CONTROL
AIRBORNE LEVELS.
Other Protective Equipment:EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA . WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN
EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
Supplemental Safety and Health
FED REGULATORY INFO: UNDER CWA. OSHA: NONE OF CHEMS IN THIS PROD ARE
CONSIDERED HIGHLY HAZ BY OSHA. SECTION 302(RQ): NONE OF CHEMS IN
MATL HAVE RQ. SECTION 302(TPQ): NONE OF CHEMS IN PROD HAVE TPQ. OS
HA: NONE OF CHEMS IN PROD ARE CONSIDERED HIGH HAZ BY OSHA.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NOT AVAILABLE
Melt/Freeze Pt:=60.C, 140.F
Vapor Pres:NOT AVAILABLE
Vapor Density:NOT AVAIL
Spec Gravity:1.20
pH:NOT AVAIL
Viscosity:NOT AVAIL
Solubility in Water:SOLUBLE
Appearance and Odor:WHITE SOLID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:INCOMPATIBLE MATERIALS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
=================== Toxicological Information===================
Toxicological Information:LD50/LC50: CAS# 25322-68-3: ORAL,MOUSE = 34
GM/KG; ORAL, RABBIT: LD50 = 14 GM/KG; ORAL, RAT: DL50 = 28 GM/KG;
SKIN, RABBIT: LD50 = >20 GM/KG. EPIDEMIOLOGY, TERATOGENICITY,
REPRODUCTIVE EFFECTS, NEUROT OXICITY, MUTAGENICITY, AND OTHER
STUDIES: NO DATA AVAILABLE.
===================== Ecological Information =====================
Ecological:ECOTOXICITY, ENVIRONMENTAL FATE, PHYSICAL/CHEMICAL AND
OTHER: NOT AVAILABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE, AND LOCAL REGULATIONS. RCRA D-SERIES MAX CONC OF
CONTAMINANTS: NONE LISTED. RCRA D-SERIES CHRONIC TOXICITY REFERENCE
LEVELS: NONE LISTED. RCRA F, P, & U SERIES: NONE LISTED.
=================== MSDS Transport Information ===================
Transport Information:NO INFORMATION AVAILABLE.
===================== Regulatory Information =====================
SARA Title III Information:NO CHEMICAL ARE REPORTABLE UNDER SECTION
313.
Federal Regulatory Information:TSCA CAS #25322-68-3 IS LISTED ON TSCA
INVENTORY. HLTH & SFTY RPTG LIST: NONE OF CHEMS IN PROD ARE UNDER
CHEM TEST RULE. SECTON 12B: NONE OF CHEMS ARE LISTED UNDER TSCA
SECTION 12B. TSCA SIGNIFICANT N EW USE FULE: NONE OF CHEMS IN MATL
HAVESNUR UNDER TSCA. CLEAN AIR ACT: THIS MATL DOES NOT CNTN ANY HAZ
AIR POLLUTANTS. THIS MATL DOES NOT CNTN ANY CLASS 1 OZONE
DEPLETORS. THIS MATL DOES NOT CNTN ANY CLASS 2 OZONE DEPLETORS.
CLEAN WATER ACT: NONE OF CHEMS IN PROD ARE LISTED AS HAZ SUBSTANCES
UNDER C WA. NONE OF CHEMS IN PROD ARE LISTED AS TOXIC POLLUTANTS
(SUPDAT)
State Regulatory Information:CAS# 25322-68-3 CAN BE FOUND ON FOLLOWING
STATE RIGHT TO KNOW LISTS: MINNESOTA. CALIFORNIA NO SIGNIFICANT
RISK LEVEL: NONE OF CHEMS IN THIS PROD ARE LISTED.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MEECO MANUFACTURING INC
CAGE:64482
CAGE:64482
============= Composition/Information on Ingredients =============
Ingred Name:SOAP
Ingred Name:KEROSENE/#1 STOVE OIL
CAS:8008-20-6
RTECS #:OA5500000
Other REC Limits:100 MG/CUM NIOSH
Ingred Name:CALCIUM SULFONATE
CAS:68783-96-0
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION/INGESTION: HARMFUL/FATAL.
SKIN: DISCOMFORT & IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION/INGESTION: HARMFUL/FATAL. SKIN:
DISCOMFORT & IRRITATION.
======================= First Aid Measures =======================
First Aid:SKIN: WASH EXPOSED AREA W/SOAPY WATER. EYES: WASH W/WATER FOR
15 MINS. INGESTION: DON'T INDUCE VOMITING. INHALATION: REMOVE TO
FRESH AIR. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:152F
Extinguishing Media:DRY CHEMICAL
Fire Fighting Procedures:TREAT AS PETROLEUM DISTILLATE FIRE.
Unusual Fire/Explosion Hazard:COMBUSTIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP W/ABSORBENT MATERIAL. CLEAN AREA
W/WATER & PETROLEUM CUTTING DETERGENT.
======================Handling and Storage ======================
Handling and Storage Precautions:COMBUSTIBLE. KEEP AWAY FROM OPEN
FLAMES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE USUALLY REQUIRED
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:315F
Vapor Pres:1
Vapor Density:3.9
Spec Gravity:0.867
Appearance and Odor:DIESEL OIL ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:OPEN FLAMES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. COMBUSTIBLE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:KEX RUB-R-FLUX SILICONE SOAPSTONE REMOVER 7
CAGE:5L381
CAGE:5L381
============= Composition/Information on Ingredients =============
Ingred Name:XYLENE
CAS:1330-20-7
RTECS #:ZE2100000
OSHA PEL:100 PPM;150 PPM STEL
ACGIH TLV:100 PPM;150 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BENZENE, ETHYL-; (ETHYL BENZENE)
CAS:100-41-4
RTECS #:DA0700000
OSHA PEL:100 PPM;125 PPM STEL
ACGIH TLV:100 PPM;125 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHANE, 1,1,1-TRICHLORO-; (1,1,1-TRICHLOROETHANE)
CAS:71-55-6
RTECS #:KJ2975000
OSHA PEL:350 PPM;450 PPM STEL
ACGIH TLV:350 PPM;450 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DIZZ, NAUSEA, HDCH, LOSS OF COORD &
EQUILIBRIUM, UNCON, POSS CNS DMG & DEATH IN POORLY VENTED AREA.
IRRIT OF EYES & SKIN. LIQUID INGESTION MAY RESULT IN IRRIT TO
MOUTH, GI TRACT, VOMIT & SUBSEQUENT AS PIR MAY LEAD TO CHEMICAL
PNEUMONIA & PULMONARY EDEMA. 1,1,1-TRICHLOROETHANE MAY CAUSE
ALLERGIC RXN.(SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:CHLOROCARBON MATERIALS HAVE PRODUCED
SENSITIZATION OF THE MYOCARDIUM TO EPINEPHRINE IN LABORATORY
ANIMALS & COULD HAVE A SIMILAR EFFECT IN HUMANS. ADRENOMIMETICS
(E.G., EPINEPHRINE) MAY BE CO NTRAINDICATED EXCEPT FOR
LIFE-SUSTAINING USES IN HUMANS ACUTELY OR CHRONICALLY EXPOSED TO
CHLOROCARBONS .
Medical Cond Aggravated by Exposure:HEART DISEASE.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTF RESP.
EYE:FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN. SKIN:WASH W/SOAP &
WATER. REMOVE CONTAMINATED SHOES & CLOTHING. IF IRRITATION RESULTS,
CALL MD . INGEST:DO NOT INDUCE VOMITING. IF VOMITING OCCURS, KEEP
HEAD BELOW HIPS TO PREVENT ASPIRATION OF VOMITUS INTO LUNGS.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEMICAL OR CARBON
DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
& FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:BY-PRODUCTS OF PRODUCT CAUSED BY BURNING.
THERMAL DECOMPOSITION PRODUCTS MAY INCLUDE HCL & PHOSGENE .
================== Accidental Release Measures ==================
Spill Release Procedures:PERSONNEL W/PROPER PROTECTIVE EQUIPMENT SHOULD
CONTAIN SPILL. USE INERT ABSORBENT MATERIAL TO SOAK UP SPILL. PLACE
IN TIGHTLY SEALED CONTAINERS PROPERLY LABELLED FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM OXIDIZING AGENTS IN
COOL, DRY PLACE W/ADEQUATE VENTILATION.
Other Precautions:CNTCT LENSES SHOULD NOT BE WORN WHEN WORKING
W/CHEMICAL. NO SMOKING IN AREA OF USE. DO NOT USE IN THE GENERAL
VICINITY OF ARC WELDING, OPEN FLAMES OR HOT SURFACES. HEAT &/OR UV
RADIATION MAY CAUSE THE FORMATIN OF HCL &/OR PHOSGENE .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED CHEMICAL CARTRIDGE
RESPIRATOR W/ORGANIC VAPOR CARTRIDGE(S) OR ANY POWERED AIR
PURIFYING RESPIRATOR W/ORGANIC CARTRIDGE(S).
Ventilation:MECHANICAL (GENERAL) AS REQUIRED TO MAINTAIN VAPOR
CONCENTRATIONS BELOW PERMISSIBLE LEVELS.
Other Protective Equipment:WEAR APPROP EQUIP TO PVNT RPTD/PRLNGD SKIN
CNTCT. WASH IMMED UPON CONTAM. IMMED REMOVE ANY CLTHG THAT (SUPP
DATA)
Work Hygienic Practices:FOLLOW DIRECTIONS ON PRODUCT LABEL. PRACTICE
GOOD HABITS OF CLEANLINESS.
Supplemental Safety and Health
OTHER PROT EQUIP:BECOMES WET TO AVOID FLAMMABILITY HAZARD.
================== Physical/Chemical Properties ==================
HCC:T4
Boiling Pt:B.P. Text:162F,72C
Spec Gravity:1.277 @ 74F
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID, ETHER-LIKE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CAUSTIC SODA, CAUSTIC POTASH OR OXIDIZING MATERIALS.
Stability Condition to Avoid:OPEN FLAMES, HOT GLOWING SURFACES OR
ELECTRIC ARCS.
Hazardous Decomposition Products:(FROM BURNING):HYDROGEN CHLORIDE,
POSSIBLE TRACES OF PHOSGENE, CO & UNIDENTIFIED COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL IS TO BE I/A/W FEDERAL, STATE AND LOCAL
REGULATIONS AND AT AN APPROVED WASTE MANAGEMENT FACILITY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SUPER FAST SET CEMENT
CAGE:CTSCE
CAGE:CTSCE
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE-FUSED; (SILICON DIOXIDE) (SIO*2)
CAS:60676-86-0
RTECS #:VV7328000
Fraction by Wt: 15%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CORUNDUM; (ALUMINUM OXIDE) (AL*2O*3)
CAS:1302-74-5
RTECS #:GN0231000
Fraction by Wt: 14%
OSHA PEL:5 MG/M3 RESP DUST
ACGIH TLV:10 MG/M3 (AL*2O*3)
Ingred Name:IRON OXIDE; (FE*2O*3)
CAS:1332-37-2
RTECS #:NO7380000
Fraction by Wt: 2%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3 FUME (FE)
Ingred Name:CALCIUM OXIDE; (CAO)
CAS:1305-78-8
RTECS #:EW3100000
Fraction by Wt: 51%
OSHA PEL:5 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:MAGNESIUM OXIDE; (MGO)
CAS:1309-48-4
RTECS #:OM3850000
Fraction by Wt: 1%
OSHA PEL:15 MG/M3 PARTICULATE
ACGIH TLV:10 MG/M3 FUME
Ingred Name:SULFUR TRIOXIDE; (SO*3) (SARA 302)
CAS:7446-11-9
RTECS #:WT4830000
Fraction by Wt: 13%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:LOSS ON IGNITION
RTECS #:9999999ZZ
Fraction by Wt: 3%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:INSOLUBLE MATTER; (INSOLUBLE RESIDUE)
Fraction by Wt: 3%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:DRY CEMENT, WHEN COMBINED W/BODY
MOISTURE & WET CEMENT, ESP AS ING IN PLASTIC (UNHARDENED) CONCRETE,
CAN DRY SKIN & CAUSE ALKALI BURN. CEMENT DUST CAN IRRITATE EYES &
UPPER RESPIRATORY SYSTEM. C HRONIC:CEMENT DUST CAN CAUSE
INFLAMMATION OF THE LINING TISSUE OF THE INTERIOR OF NOSE & INFLAMM
OF (EFTS OF OVEREXP)
Explanation of Carcinogenicity:CRYSTALLINE SILICA:IARC MONOGRAPHS,
SUPP, VOL 7, PG 341, 1987:GROUP 2A.
Effects of Overexposure:HLTH HAZ:CORNEA. HYPERSENSITIVE INDIVIDUALS MAY
DEVELOP ALLERGIC DERMATITIS. (CEMENT MAY CONTAIN TRACES OF
HEXAVALENT CHROMIUM).
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . EYES:IRRIGATE W/WATER FOR
AT LEAST 15 MINUTES. SKIN:WASH AFFECTED AREAS OF BODY W/SOAP & WA
TER.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:USE DRY CLEAN-UP METHODS THAT DO NOT DISPERSE
DUST INTO THE AIR. AVOID BREATHING DUST.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PRECAUTIONS MUST BE OBSERVED BECAUSE
CEMENT BURNS OCCUR W/LITTLE WARNING. LITTLE HEAT IS SENSED.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN DUSTY ENVIRONMENTS, THE USE OF NIOSH/MSHA
APPROVED RESPIRATOR IS RECOMMENDED.
Ventilation:LOCAL EXHAUST CAN BE USED, IF NECESSARY, TO CONTROL
AIRBORNE DUST LEVELS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . USE BARRIER CREAMS, BOOTS & CLTHG TO
(SUPDAT)
Work Hygienic Practices:IMMEDIATELY AFTER WORKING W/CEMENT, WORKERS
SHOULD SHOWER W/SOAP & WATER.
Supplemental Safety and Health
OTHER PROT EQUIP:PROTECT SKIN FROM PROLONGED CONTACT W/CEMENT,
ESPECIALLY WET CEMENT IN PLASTIC CONCRETE.
================== Physical/Chemical Properties ==================
Spec Gravity:3.1
Solubility in Water:SLIGHT (0.1-1%)
Appearance and Odor:GRAY (OR WHITE) POWDER; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:ALTHOUGH NO HAZARDOUS REACTION WILL OCCUR,
RAPID SET PRODUCTS SHOULD BE KEPT DRY UNTIL USED.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . MATERIAL CAN BE RETURNED TO CONTAINER FOR LATER USE,
OR IT CAN BE DISPOSED OF AS COMMON WASTE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS & NATURAL/SYNTHETIC RUBBER COMPOSITION
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PHARMADINE TOPICAL SOLUTIONS
CAGE:60907
CAGE:60907
============= Composition/Information on Ingredients =============
Ingred Name:POVIDONE (IODINE)
CAS:25655-41-8
RTECS #:TR1579600
Fraction by Wt: 68%
Ingred Name:WATER, H2O
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 32%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RATS) 20 ML/KG
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MAY CAUSE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: MAY CAUSE IRRITATION.
Medical Cond Aggravated by Exposure:MAY CAUSE ALLERGIC SKIN REACTION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER. INHALATION: REMOVE FROM AREA. SKIN: WASH
W/WATER. INGESTION: INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:WATER
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:COVER W/INERT MATERIAL & REMOVE. FLUSH AREA
W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL PLACE. HEAT CAUSES
DECREASE IN AVAILABLE IODINE & DROP IN PH.
Other Precautions:AVOID PROLONGED EXPOSURE OF SKIN TO A POOL OF
SOLUTION. AVOID MIXING ALCOHOL W/SOLUTION ON THE SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED IN NORMAL USE.
Ventilation:NOT REQUIRED
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Vapor Pres:.00075(I2)
Vapor Density:8.8 (I2)
Spec Gravity:1.032
Evaporation Rate & Reference:1
Solubility in Water:MISCIBLE
Appearance and Odor:DARK BROWN LIQUID, ODORLESS
Percent Volatiles by Volume:68%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY REACT WITH REDUCING COMPOUNDS.
Stability Condition to Avoid:PROTECT FROM HEAT OR FREEZING. STORE AT
5-30C.
Hazardous Decomposition Products:MAY RELEASE VAPORS OF IODINE &
HYDROGENIODIDE UNDER COMBUSTION CONDITIONS OR CONTACT WITH STRONG
ACIDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:REMOVE TO APPROVED DISPOSAL FACILITY.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:DISINFECTANT SPRAY
CAGE:64682
CAGE:64682
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ALCOHOL (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: >50%
Other REC Limits:1900 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9192
Ingred Name:ALKANES, C-3 TO C-4
CAS:68475-59-2
Fraction by Wt: 10-20%
Other REC Limits:800 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: TEMPORARY IRRITATION. INGESTION:
SAME AS ALCOHOL INTOXICATION. INHALATION: AT HIGH VAPOR LEVELS MAY
CAUSE IRRITATION, ALCOHOL INTOXICATION SYMPTOMS, HEADACHE &
DIZZINESS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: TEMPORARY IRRITATION. INGESTION: SAME AS
ALCOHOL INTOXICATION. INHALATION: AT HIGH VAPOR LEVELS MAY CAUSE
IRRITATION ALCOHOL INTOXICATION SYMPTOMS, HEADACHE, & DIZZINESS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. CALL PHYSICIAN. INHALATION:
REMOVE TO FRESH AIR. INGESTION: GIVE WATER OR MILK. CALL PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:71F
Lower Limits:4%
Upper Limits:19%
Extinguishing Media:WATER FOG, CO2, DRY CHEMICAL
Fire Fighting Procedures:KEEP CONTAINERS COOL. USE SHIELDING TO PROTECT
PERSONNEL AGAINST BURSTING, RUPTURING & VENTING CONTAINERS.
Unusual Fire/Explosion Hazard:AT ELEVATED TEMPERATURES (>130F)
CONTAINERS MAY VENT, RUPTURE, & BURST.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF FLAMES, SPARK & HEAT. WIPE
UP SPILLS THEN RINSE W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN. DON'T
STORE WHERE TEMPERATURES >130F. CONTENTS UNDER PRESSURE. READ
ENTIRE LABEL BEFORE USING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Ventilation:MECHANICAL: MAINTAIN ADEQUATE VENTILATION.
Other Protective Equipment:NONE REQUIRED
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:180F
Vapor Pres:30
Vapor Density:>1
Spec Gravity:0.87
Evaporation Rate & Reference:(BU AC = 1): >1
Solubility in Water:APPRECIABLE
Appearance and Odor:CLEAR THIN LIQUID PLEASANTLY SCENTED.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:FLAMES, SPARKS, HEAT
Hazardous Decomposition Products:OXIDES OF CARBON
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T PUNCTURE OR INCINERATE CONTAINERS. REPLACE
CAP & DISCARD CONTAINERS IN TRASH.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:CRAYOLA CRAYONS, 52-3124
Preparer's Name:PHILLIP E MOLL
CAGE:85419
CAGE:85419
============= Composition/Information on Ingredients =============
Ingred Name:CLAY (KAOLIN); ALUMINUM SILICATE
CAS:1332-58-7
RTECS #:GF1670500
OSHA PEL:10 MG/M3 TDUST;5RESP
ACGIH TLV:2 MG/M3 DUST
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (HYDROUS
CALCIUM MAGNESIUM SILICATE)
CAS:14807-96-6
RTECS #:WW2710000
OSHA PEL:2 MG/M3 RESP
ACGIH TLV:2 MG/M3 RESP
Ingred Name:IRON (III) OXIDE; (PIGMENT RED 101)
CAS:1309-37-1
RTECS #:NO7400000
OSHA PEL:10 MG/M3
ACGIH TLV:5 MG/M3 (FE)
Ingred Name:COPPER (SARA III)
CAS:7440-50-8
RTECS #:GL5325000
OSHA PEL:0.1MG/M3 FUME; 1DUST
ACGIH TLV:0.2MG/M3 FUME; 1DUST
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:DOES NOT APPLY.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.
CONTACT A PHYSICIAN. SKIN:WASH WITH SOAP AND WATER. INGEST:DO NOT
INDUCE VOMITING. CONTACT PHYSICIAN OR POISON CONTROL CENTER. INHAL:
REMOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>365F; ASTM D-92
Lower Limits:0.9%
Upper Limits:7.0%
Extinguishing Media:ABC DRY CHEMICAL, CO2, FOAM, SAND OR SODIUM
BICARBONATE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT
EQUIP.HANDLE THE SAME AS ANY WAX FIRE. IF STORED IN LARGE QTYS IN
AN ENCLOSED AREA, USE AIR-SUPPLIED RESCUE EQUIP.
Unusual Fire/Explosion Hazard:DO NOT STORE WITH STRONG OXIDIZERS.
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER FREE PRODUCT. KEEP PRODUCT OUT OF
SEWERS & WATERCOURSES BY DIKING OR IMPOUNDING. ADVISE AUTHORITIES
IF PRODUCT ENTERS SEWERS OR WATERCOURSES. ASSURE CONFORMITY WITH
APPLICABLE GOVERNMENTAL REG ULATIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE NOT TO
EXCEED 105F.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED.
Ventilation:NONE REQUIRED.
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
VP:@ 20C.:0.01-1.0MM @ 180C.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>575F,302C
Vapor Pres:SUPP DATA
Vapor Density:5-9.8
Spec Gravity:0.81-0.85 @ 75C
Evaporation Rate & Reference:LESS THAN 0.01
Solubility in Water:>0.01% @ 1ATM & 25C.
Appearance and Odor:64 VARIOUS COLORS-SLIGHT PARAFFIN (WAX) ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CHLORINATED SOLVENTS WILL DISSOLVE PRODUCT.
Stability Condition to Avoid:AVOID CNTCT W/STRONG OXIDANTS; SUCH AS LIQ
CHLORINE, CONCENTRATED OXYGEN, SODIUM HYPOCHLORITE OR CALCIUM
HYPOCHLORITE.
Hazardous Decomposition Products:CARBON MONOXIDE IN CASE OF INCOMPLETE
COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL
REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:KRYTOX 1500 SERIES FLUORINATED VACUUM PUMP
Preparer's Name:ROBERT V. DAUM
CAGE:B0589
CAGE:B0589
CAGE:18873
============= Composition/Information on Ingredients =============
Ingred Name:PERFLUOROALKYLETHER; (FLUORINE END-CAPPED HOMOPOLYMERS OF
HEXAFLUOROPROPYLENE EPOXIDE)
CAS:60164-51-4
Fraction by Wt: 100%
Other REC Limits:20 PPM 8 HR TWA(MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROD IS A MILD EYE IRRITANT. CAUSED
LUNG IRRITATION, PULMONARY EDEMA AND DEATH IN ANIMALS EXPOSED TO
DECOMP PRODUCTS. SKIN:CONTACT MAY CAUSE IRRIT W/DISCOMPFORT/RASH.
PRLNGD CONTACT MAY CAUSE REDNESS & INFLAMM OF HAIR FOLLICLES
WITHOUT SKIN SENSIT. EYE:MAY CAUSE IRRIT W/DISCOMFORT,
TEARING/BLURRING (EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:NOT RELEVENT
Effects of Overexposure:HLTH HAZ:OF VISION. INHAL:SMOKE FROM TOBACCO
COMTAM W/PROD MAY CAUSE THROAT IRRIT, COUGH & TIGHTNESS IN CHEST.
INHAL OF DECOMP PROD FORMED AT AROUND 554F (290C) MAY CAUSE LUNG
IRRIT FROM FLUORINE COMP OUNDS AND DELAYED PULMONARY EDEMA
REQUIRING MEDICAL TREATMENT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTIF RESP. IF
BRTHG IS DIFF, GIVE O2. CALL MD. SKIN:FLUSH W/WATER AFTER CONTACT.
WASH CONTAM CLTHG BEFORE REUSE. EYE:IMMED FLUSH W/PLENTY OF WATER
FOR AT LEAST 15 MIN. CALL MD. INGEST:DO NOT INDUCE VOMIT. IMMED
GIVE 2 GLASSES OF WATER. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. CALL MD. NOTE TO MD: ACTIVATED CHARCOAL SLURRY
(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:DOES NOT IGNITE.
Extinguishing Media:AS APPROPRIATE FOR COMBUSTIBLES IN AREA.
Fire Fighting Procedures:EVACUATE PERSONNEL TO A SAFE AREA. WEAR
NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:DECOMPOSITION AT FLAME TEMPERATURES MAY
FORM TOXIC FLUORIDE COMPOUNDS. AVOID BREATHING DECOMP PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:USE APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT
DURING CLEAN UP. SOAK UP WITH SAWDUST, SAND, OIL DRY OR OTHER
ABSORBENT MATERIAL. SHOVEL OR SWEEP UP. PLACE IN CONTAINER FOR
DISPOSAL. REMOVE SOURCES OF H EAT AND FLAME.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. DO NOT
STORE OR CONSUME FOOD, DRINK OR TOBACCO IN AREAS WHERE THEY MAY
BECOME CONTAMINATED WITH MATERIAL.
Other Precautions:KEEP AWAY FROM HEAT AND FLAME TO AVOID DECOMPOSITION
PRODUCTS. USE ONLY WITH ADEQUATE VENTILATION. AVOID CONTACT WITH
EYES AND SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:USE WITH ADEQUATE VENTILATION.
Other Protective Equipment:WHERE THERE IS POTENTIAL FOR SKIN CONTACT
HAVE AVAILABLE AND WEAR AS APPROPRIATE, APRON, PANTS AND JACKET.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:FLUIDS/OILS. HAZ DECOMP PROD:SOME METAL OXIDES
AT TEMP ABOVE 288C. DECOMP OCCURS AT INCREASING RATES AS TEMP IS
RAISED ABOVE 355C. FIRST AID PROC:MAY BE ADMIN. TO PREPARE ACTI
VATED CHARCOAL SLURRY, SUSPEND 50 GRAMSACTIVATED CHARCOAL IN 400ML
H2O & MIX THORO. ADMIN 5 ML/KG OR 350 ML FOR ADULT.
================== Physical/Chemical Properties ==================
HCC:V6
Spec Gravity:1.86-1.91 @ 75F
pH:NEUT
Solubility in Water:NEGLIBIBLE
Appearance and Odor:COLORLESS LIQUID, VISCOUS OIL WITH NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE REASOLABLY FORESEEABLE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:HEATING ABOVE 500F (260C) MAY FORM
POTENTIALLY TOX FLUORINE COMPOUNDS. DEPOLYMERIZATION MAY OCCUR IN
PRES OF (SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:TREATMENT, STORAGE, TRANSPORTATION & DISPOSAL
MUST BE I/A/W APPLIC FEDERAL, STATE/PROVINCIAL & LOCAL REGULATIONS.
RECOVER NONUSABLE FREE LIQUID & DISPOSE OF IN AN APPROVED &
PERMITTED INCINERATOR. DO NOT FLUSH TO SURFACE WATER/SANITARY
SEWER SYSTEM.
| 1 | gloves_mandatory |
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.