text
stringlengths 542
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:LPS HARDCOAT, 03355
CAGE:66724
CAGE:66724
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC; (ALIPHATIC
HYDROCARBON)
CAS:64742-88-7
Fraction by Wt: 40-60%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DISTILLATES,PETROLEUM,VACUUM; (PETROLEUM OIL (SEVERELY
HYDROTREATED))
CAS:70592-78-8
Fraction by Wt: 10-15%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DIPROPYLENE GLYCOL, MONOMETHYL ETHER; (DIPROPYLENE GLYCOL
METHYL ETHER)
CAS:34590-94-8
RTECS #:JM1575000
Fraction by Wt: 2-3%
OSHA PEL:100 PPM, S
ACGIH TLV:100 PPM;150 STEL, S
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:HEADACHE, DIZZINESS,
NAUSEA AND ANESTHETIC EFFECTS. EYES:IRRITATION. SKIN:REPEATED OR
PROLONGED CONTACT MAY CAUSE DRYING AND DEFATTING OF SKIN.
INGEST:LOW ORDER OF ORAL TOXICITY; HOWEVER M INUTE AMOUNT ASPIRATED
INTO LUNGS DURING INGESTION MAY CAUSE SEVERE PULMONARY INJURY.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE TO FRESH AIR AND CONTACT MD. ADMIN OXYGEN IF BRTHG
IS DIFFICULT. EYES:FLUSH EYES W/PLENTY OF WATER FOR AT LEAST 15 MIN
AND CONTACT MD. SKIN:WASH WITH SOAP AND WATER; APPLY MEDICATED SKIN
CR EAM. INGEST:CONTAINS ALIPHATIC HYDROCARBONS AND PETROLEUM OIL.
DO NOT INDUCE VOMITING. IF VOM OCCURS SPONTANEOUSLY, KEEP HEAD
BELOW HIPS TO PREVENT ASPIRATION OF LIQUID INTO LUNGS. CONTACT MD
IMMED.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:105F,41C
Lower Limits:0.7%
Upper Limits:6.0%
Extinguishing Media:FOAM, DRY CHEMICAL, OR CARBON DIOXIDE. DO NOT USE A
DIRECT STREAM OF WATER.
Fire Fighting Procedures:NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . WATER FOG MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA BY OPENING DOORS & WINDOWS. REMOVE
IGNIT SOURCES. REMOVE LEAKING CONTAINER & TRANSFER REMAINING
PRODUCT TO ANOTHER VESSEL. PREVENT PROD FOR GOING INTO SEWERS &
WATER SOURCES BY DIKING OR IMP OUNDING. USING APPROP SAFETY EQUIP,
(SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BULK BELOW 120F AND ABOVE 32F.
STORE AWAY FROM IGNITION SOURCES AND AVOID BREATHING VAPORS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED IF GOOD VENTILATION IS MAINTAINED.
FOR ENCLOSED AREAS, USE NIOSH/MSHA APPROVED ORGANIC VAPOR CARTRIDGE
RESPIRATOR OR SCBA.
Ventilation:LOC EXHAUST IS USUALLY ADEQ. HOWEVER, MECH VENT SHOULD BE
USED WHEN SPRAYING IN ENCLOSED AREA. VAP CONC SHOULD (SUPDAT)
Other Protective Equipment:AS NECESSARY TO PREVENT PROLONGED OR
REPEATED SKIN CONTACT.
Work Hygienic Practices:WASH HANDS W/SOAP & WATER AFTER USE/OR BEFORE
BREAKS, LUNCH & AT END OF WORK PERIODS. REMOVE CONTAM CLTHG & (SUPP
DATA)
Supplemental Safety and Health
VENT:BE MINIMIZED AS MUCH AS POSSIBLE. WORK HYGENIC PRAC:LAUNDER BEFORE
REUSE. SPILL PROC:MOP UP OR SOAK UP WITH ABSORBNENT MATERIAL, SUCH
AS SAND OR CLAY.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:315F,157C
Vapor Pres:<5
Vapor Density:4.8-5.3
Spec Gravity:0.872 (H*2O=1)
Evaporation Rate & Reference:.12 (N-BUTYL ACETATE=1)
Solubility in Water:NIL
Appearance and Odor:DARK BROWN LIQUID WITH SWEET, MILD ODOR.
Percent Volatiles by Volume:53
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING
Stability Condition to Avoid:AVOID SPARKS OR OPEN FLAMES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS FOR PETROLEUM DISTILLATES. RCRA HAZ WASTE NO:
THIS MATL HAS THE RCRA CHARACTERISTIC OF IGNITABILITY AND IF
DISCARDED IN ITS PURCHASEDFORM WOULD HAVE THE HAZ WASTE NUMBER
DOO1.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:4-METHYL-2-PENTANONE, O-809
CAGE:84898
CAGE:84898
CAGE:8Y898
============= Composition/Information on Ingredients =============
Ingred Name:2-PENTANONE, 4-METHYL-; (METHYL ISOBUTYL KETONE) (SARA
III). LD50:(ORAL,RAT) 2080 MG/KG.
CAS:108-10-1
RTECS #:SA9275000
OSHA PEL:100 PPM
ACGIH TLV:50 PPM;75 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ALL CHEMICALS SHOULD BE CONSIDERED
HAZARDOUS - AVOID DIRECT PHYSICAL CONTACT! MAY BE HARMFUL IF
ABSORBED THROUGH SKIN, INHALED OR SWALLOWED. CAN CAUSE SKIN OR EYE
IRRITATION. CAN BE IRRITATING TO MUCO US MEMBRANES. VAPORS &/OR
DIRECT EYE CONTACT CAN CAUSE SEVERE EYE BURNS. PROLONGED EXPOSURE
MAY CAUSE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:NAUSEA, HEADACHE, DIZZINESS &/OR EYE
DAMAGE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMED . EYES:FLUSH CONTINUOUSLY W/WATER FOR AT
LST 15-20 MINS. SKIN:FLUSH W/WATER FOR 15-20 MINS. IF NO BURNS HAVE
OCCURRED - USE SOAP & WATER TO CLEANSE SKIN. INHAL:REMOVE PATIEN T
TO FRESH AIR. ADMIN OXYGEN IF PATIENTIS HAVING DFCLTY BRTHG. IF
PATIENT HAS STOPPED BRTHG ADMIN ARTF RESP. IF PATIENT IS IN CARDIAC
ARREST ADMIN CPR. CONTINUE LIFE SUPPORTING MEASURES UNTIL(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:55.4F,13.0C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER OR SPRAY.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:THIS IS A FLAMMABLE CHEMICAL. NO
EXPLOSION LIMITS ARE AVAILABLE FOR THIS COMPOUND.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR APPROPRIATE OSHA REGULATED
EQUIPMENT. VENTILATE AREA. ABSORB ON VERMICULITE OR SIMILAR
MATERIAL. SWEEP UP & PLACE IN AN APPROPRIATE CONTAINER. HOLD FOR
DISPOSAL. WASH CONTAMINATED SURFACES TO REMOVE ANY RESIDUES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT W/SKIN, EYES & CLOTHING.
KEEP TIGHTLY CLOSED IN A COOL, DRY PLACE. STORE ONLY W/COMPATIBLE
CHEMICALS. FLAMMABLE. HYGROSCOPIC.
Other Precautions:THIS PRODUCT IS FURNISHED FOR LABORATORY USE ONLY!
MFR'S PRODUCTS MAY NOT BE USED AS DRUGS, COSMETICS, AGRICULTURAL OR
PESTICIDAL PRODUCTS, FOOD ADDITIVES OR AS HOUSEHOLD CHEMICALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:THIS CHEMICAL SHOULD ONLY BE HANDLED IN A HOOD.
Other Protective Equipment:USE APPROPRIATE NIOSH/MSHA APPROVED SAFETY
EQUIPMENT. ANSI APPROVED EYE WASH FOUNTAIN / DELUGE SHOWER .
Work Hygienic Practices:CONTACT LENSES SHOULD NOT BE WORN IN THE
LABORATORY.
Supplemental Safety and Health
FIRST AID PROC:MED ASSISTANCE HAS ARRIVED. NOTE:AN ANTIDOTE IS A
SUBSTANCE INTENDED TO COUNTERACT EFT OF A POIS. IT SHOULD BE ADMIN
BY MD/TRAINED EMER PERS. MED ADVICE CAN BE OBTAINED FROM POIS CTL
CT R.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:244F,118C
Melt/Freeze Pt:M.P/F.P Text:-112F,-80C
Solubility in Water:SLIGHTLY SOLUBLE
Appearance and Odor:COLORLESS LIQUID; FRUITY/PLEASANT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE W/STRONG BASES, STRONG ACIDS, STRONG REDUCING AGENTS,
STRONG OXIDIZING AGENTS & HALOGENS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:DECOMPOSITION LIBERATES TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . BURN IN A CHEMICAL INCINERATOR EQUIPPED W/AFTERBURNER
& SCRUBBER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:173 6594 EKTACHEM LIQUID CALIBRATOR 16
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: >98%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM CHLORIDE
CAS:7647-14-5
RTECS #:VZ4725000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLY(1-VINYL-2-PYRROLIDINONE)
CAS:9003-39-8
RTECS #:TR8160000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM BICARBONATE
CAS:144-55-8
RTECS #:VZ0950000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:P-HYDROXYBENZOIC ACID, METHYL ESTER (METHYLPARABEN)
CAS:99-76-3
RTECS #:DH2450000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:CHLORAMPHENICOL (CHLOROMYCETIN)
CAS:56-75-7
RTECS #:AB6825000
Fraction by Wt: <0.1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:BARBITURIC ACID (PHENOBARBITAL)
CAS:50-06-6
RTECS #:CO6825000
Fraction by Wt: <0.1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:HUMAN PROTEIN/HUMAN-BASED PROTEIN
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS UNKNOWN.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
Effects of Overexposure:LOW HAZARD FOR RECOMMENDED HANDLING.
======================= First Aid Measures =======================
First Aid:IN CASE OF CONTACT WITH EYE, MOUTH, OTHER MUCOUS MEMBRANE,
NON-INTACT SKIN OR PARENTERAL CONTACT, REPORT INCIDENT TO
SUPERVISOR AND/OR MEDICAL DEPARTMENT OF EMPLOYER IN ACCORDANCE WITH
29 CFR 1910.103 0 (FINAL RULE)- BLOODBORNE PATHOGENE-NOVEMBER 22,
1991. INHALED:MOVE TO FRESH AIR. EYES/SKIN:FLUSH WITH WATER FOR 15
MINUTES. THEN WASH SKIN WITH SOAP & WATER. ORAL:RINSE MOUTH WITH
WATER.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING WHEN FIGHTING CHEMICAL FIRE.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:DISINFECT WITH A 5.25% SODIUM HYPOCHLORITE
SOLUTION (HOUSEHOLD BLEACH) DILUTED WITH 9 PARTS WATER & LEAVE
UNDISTURBED FOR AT LEAST 30 MINUTES. ABSORB SPILL WITH VERMICULITE
& TRANSFER TO PROPER CONTAI NER FOR DISPOSAL. CLEAN SURFACE
THOROUGHLY.
Neutralizing Agent:A 5.25% SODIUM HYPOCHLORITE SOLUTION (HOUSEHOLD
BLEACH) + 9 PARTS WATER
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. STORE BETWEEN
46F (8C) AND 36F (2C). HANDLE AS IF POTENTIALLY INFECTIOUS AND
FOLLOW UNIVERSAL PRECAUTIONS.
Other Precautions:MINIMIZE POTENTIAL FOR PRODUCTION OF AEROSOLS. USE
WITH ADEQUATE VENTILATION. AVOID BREATHING MIST/DUST. AVOID CONTACT
WITH EYES, SKIN AND CLOTHING. WASH WITH SOAP AND WATER. KEEP OUT OF
REACH OF CHIL DREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:NORMAL GOOD GENERAL ROOM VENTILATION SHOULD BE SUFFICIENT.
Other Protective Equipment:EYE WASH STATION, QUICK DRENCH SHOWER AND
IMPERVIOUS CLOTHING
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
FORMULA CHANGED. SEE PNI A, SAME NSN. OSHA FINAL RULE 29 CFR 1910.1030
REQUIRES AN EXPOSURE CONTROL PLAN, A HEPATITIS B IMMUNIZATION
PROGRAM, A POST-EXPOSURE TREATMENT AND EVALUATION PROGRAM, AND AN E
MPLOYEE TRAINING PROGRAM. EACH UNIT WASTESTED AND DETERMINED TO BE
NEGATIVE FOR HEPATITIS B AND ANTIBODY TO HIV.
================== Physical/Chemical Properties ==================
HCC:K1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:18 @ 68F
Vapor Density:O.6
Spec Gravity:1.0
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS, ODORLESS LIQUID
Percent Volatiles by Volume:>98
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE WITH COMMON MATERIALS AND CONTAMINANTS WITH WHICH THE MATERIAL MAY
REASONABLY COME INTO CONTACT.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE OR LOCAL LAWS. CONTACT WITH A LICENSED CHEMICAL
DISPOSAL AGENCY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:WONDER WOODSTAIN, 9683 SPANISH OAK
CAGE:EO559
CAGE:EO559
CAGE:6R552
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL SPIRITS (CAS# 64742-88-7) (70-80%)
ACGIH TLV:100 PPM (MFR)
Ingred Name:IRON OXIDE
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: < 5%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
===================== Hazards Identification =====================
Effects of Overexposure:INHAL:RESP TRACT
IRRIT,HD,NAUS,DIZZY,FATIGUE,UNCONSCIOUS,RESP
ARREST.SKIN/EYE:IRRIT.(SEE SUPP DATA)
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/PLENTY OF H*2O FOR @ LEAST 15 MIN.SKIN:WASH
W/SOAP,H*2O.REMOVE SOILED CLTHG.INHAL:RMV TO FRESH AIR.IF BRTHG
STOPS USE CPR.INGEST:DONT INDUCE VOMIT.ASPIRATION OF VOMIT CAN
CAUSE CHEM PNEUMO NITIS,POSS FATAL.IN ALL CASES, GET MED ATTN
IMMED.
===================== Fire Fighting Measures =====================
Flash Point:102F(38.9C),SCC
Lower Limits:1.0
Extinguishing Media:CO*2,DRY CHEM,FOAM/OTHR NFPA APPRVD METHOD FOR
CLASS B FIRE.
Fire Fighting Procedures:FULL PROT EQUIP,SCBA.USE H*2O TO COOL CLSD
CNTNRS,PVNT PRESS
Unusual Fire/Explosion Hazard:KEEP CNTNR CLSD TIGHT.ISOLATE FROM
HEAT,FLM.CLSD CNTNRS EXP TO EXT HEAT MAY EXPLO.(SEE OTHR PRECAUT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF
IGNITION(HEAT,FLAME).DONT SMOKE.AVOID BRTHG VAPORS.BEFORE CLEAN-UP
REFER TO HAZ CAUTION INFO IN OTHR SECTIONS.VENT AREA.CONTAIN SPILL
& REMOVE W/INERT ABSORBENT,NON-SPARK TOOLS.S TORE IN CLOSED CNTNRS
UNTIL PROPERLY DISPOSED OF.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT.DONT
SMOKE.CONTINUOUS FRESH AIR FLOW TO PVNT VAP BUILDUP.DONT STORE
ABOVE 120F.KEEP CNTNR CLSD.DONT TRANSFER TO UNLABELLED CNTNRS.
Other Precautions:% VOLATILE BY VOL:79.8-86.8.SPEC
GRAVITY:0.823-0.868.UNUSUAL FIRE HAZ:DONT USE WELD/CUT TORCH
ON/NEAR CNTNR(EVEN EMPTY).IN EMER CONDTN,OVEREXP TO DECOMP PROD
HLTH HAZ.SYMP NOT IMMED.CALL DR.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP PROT DEPENDING ON
CONDITION OF USE.
Ventilation:GENL DILUTION/LOCAL EXH VENT.RMV VAPOR FROM LOW LEVELS.
Other Protective Equipment:SOLVENT RESIST SFTY EYEWEAR,SOLVENT
IMPERMEABLE CLTHG,BOOTS.
Supplemental Safety and Health
OVEREXP:INGEST:STOMACH/INTESTINE IRRIT,NAUS,VOMIT,DIARR.PERM
BRAIN/NERVOUS SYS DMG ASSOC W/RPTD,PRLNG SLVT OVEREXP.POSS LUNG
DUST DISEASE IF RPTD/PRLNG BRTHG OF SPRAY MIST/SAND DUST OVER YEARS
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:300-390F
Vapor Pres:2.0
Vapor Density:> 1
Evaporation Rate & Reference:SLOWER THAN ETHER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:MAY CAUSE HAZ FUMES WHEN HEATED TO
DECOMP-POSS CO,CO*2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW FEDERAL,STATE & LOCAL
REGULATIONS.INCINERATE ONLY IN APPROVED FACILITY.DO NOT INCINERATE
CLOSED CONTAINERS.
| 1 | gloves_mandatory |
=======================================================
Product ID: EPL 700 GENERAL PURPOSE ADHESIVE RESIN PART A
Kit Part: Y
Cage: HO791
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 65847
Cage: HO791
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: PROLONGED & REPEATED CONTACT W/SKIN MAY CAUSE
IRRITATION OR RASH. AVOID USE IF ASTHMA TYPE CONDITIONS, CHRONIC BRONCHITIS,
OTHER RESPIRATORY CONDITIONS OR SKIN ECZEMA EXIST.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: AVOID USE IF ASTHMA CONDITIONS, CHRONIC
BRONCHITIS, OTHER RESPIRATORY CONDITIONS OR SKIN ECZEMA EXIST.
First Aid: INGEST:CALL MD IMMEDIATELY (FP N). SKIN:REMOVE CLOTHING & WASH
SKIN. WASH W/WATERLESS HAND CLEANER & SOAP & WATER FOR 15 MINUTES,
THEN APPLY BARRIER CREAM. INHAL:REMOVE TO FRESH AIR. EYES:CALL MD. FLU SH
W/WARM WATER FOR AT LEAST 15 MINUTES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: USE ABSORBENT MATERIAL TO COLLECT & CONTAIN.
FLUSH W/WATER & DETERGENT.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE ACCORDING TO LOCAL, STATE & FEDERAL
REGULATIONS.
Handling And Storage Precautions: WHEN HANDLING MIXED EPOXY, AVOID BREATHING
CONTACT W/SKIN & EYES.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: >200F,>93C
Extinguishing Media: FOAM, CO*2, FOG.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). AVOID BREATHING VAPORS.
Unusual Fire/Explosion Hazard: DO NOT MIX OR STORE W/STRONG OXIDANTS.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN (FP N).
Ventilation: NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment: NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
Solubility in Water: NON SOLUBLE
Appearance and Odor: WHITE CREAMY LIQUID.
Percent Volatiles by Volume: 1%
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: STRONG ACIDS, OXIDIZERS.
Hazardous Decomposition Products: NONE SPECIFIED BY MANUFACTURER.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: EPL 700 GENERAL PURPOSE ADHESIVE RESIN PART A
Cage: HO791
Assigned IND: Y
Company Name: ADHESIVES TECHNOLOGY CORP
Street: 8041 S 228TH ST SUITE 101
Zipcode: 98032
Label Required IND: Y
Date Of Label Review: 08/24/1993
Status Code: C
Label Date: 08/24/1993
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: WHEN HANDLING AVOID BREATHING VAPORS. AVOID ALL CONTACT
W/SKIN & EYES. ACUTE:PROLONGED & REPEATED CONTACT W/SKIN MAY CAUSE
IRRITATION OR RASH. AVOID USE IF ASTHMA TYPE CONDITIONS, CHRONIC BRONCHITIS,
OTHER RESPIRATORY CONDITIONS OR SKIN ECZEMA EXIST. CHRONIC:NONE LISTED BY
MANUFACTURER.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SUPERKOOL 7857
CAGE:IO444
CAGE:IO444
CAGE:96301
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM OIL, (SEVERELY HYDROTREATED)
Fraction by Wt: <90%
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED OR FREQUENT SKIN CONTACT MAY
CAUSE IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH WITH WATER FOR AT LEAST 15 MINUTES AND SEEK
MEDICAL ATTENTION. SKIN: WASH WITH SOAP AND WATER. INHALATION:
REMOVE FROM EXPOSURE. SUPPORT BREATHING (GIVE ARTIFICIAL
RESPIRATION/OXYGEN) (FP N ). INGESTION: CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>300F,>149C
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:EXTINGUISH ALL FLAMES IN VICINITY. DIKE SPILL
AND SOAK UP ON AN INERT ABSORBENT MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE DRUMS CLOSED, AWAY FROM EXTREME
HEAT AND OPEN FLAMES.
Other Precautions:CONTAINS PETROLEUM OIL. AVOID BREATHING MIST. USE
GOOD PERSONAL HYGIENE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:GENERAL VENTILATION SUFFICIENT TO KEEP AIRBORNE
CONCENTRATIONS BELOW EXPOSURE LIMITS .
Other Protective Equipment:NONE SPECIAL.
Work Hygienic Practices:USE GOOD PERSONAL HYGIENE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:>400F,>204C
Spec Gravity:0.91 (H*2O=1)
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BROWN OIL, MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
HYDROGEN CHLORIDE, OXIDES OF SULFUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW FEDERAL, STATE, LOCAL AND CORPORATE
REGULATIONS FOR LUBRICATING OIL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:L-137, HOSPITAL ALKALI DRAIN OPENER, C-6137
CAGE:HO510
CAGE:97257
CAGE:HO510
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM HYDROXIDE (CERCLA)
CAS:1310-58-3
RTECS #:TT2100000
OSHA PEL:2 MG/M3, C
ACGIH TLV:2 MG/M3, C
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEVERITY OF INJURY DEPENDS LARGELY ON
PRODUCT CONCENTRATION & DURATION OF EXPOSURE. IMMEDIATE ACTION IS
NECESSARY TO LIMIT SEVERITY OF INJURY. CAN CAUSE MINOR IRRITATION
TO SEVERE BURNS & TISSUE DAMAG E TO EXPOSED AREAS OF BODY.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE PERS TO FRESH AIR. IF BRTHG STOPS, ADMIN ARTF
RESP. GET MED ATTN IMMED. INGEST:GIVE LG QTYS OF WATER THEN SEVERAL
GLASSES OF MILK. DO NOT INDUCE VOMIT. GET MED ATTN IMMED. EYE:FLUSH
IMMED W /LG AMTS OF WATER FOR AT LST 15 MINS, LIFTING EYELIDS
OCCAS. GET MED ATTN AT ONCE. SKIN:REMOVE CONTAM CLTHG & IMMED WASH
EXPOS AREA W/WATER FOR 15 MINS. GET MED ATTN IF NECESSARY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:AS REQUIRED BY SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:DILUTION W/WATER MAY RELEASE HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN LARGE SPILLS & PUMP TO RECOVER. SMALL
SPILLS CAN BE MOPPED UP & RECOVERED. CONTAMINATED AREA SHOULD BE
NEUTRALIZED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE. KEEP
CONTAINER CLOSED WHEN NOT IN USE. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED DUST MASK IF NECESSARY.
Ventilation:ADEQUATE VENTILATION.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:AS REQUIRED TO LIMIT SKIN CONTACT, WASH HANDS
THOROUGHLY AFTER USE.
Supplemental Safety and Health
EYE PROT:& FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Spec Gravity:1.4 (H*2O=1)
Solubility in Water:COMPLETE
Appearance and Odor:HEAVY RED LIQUID; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, ALUMINUM.
Stability Condition to Avoid:EXTREME TEMPERATURES.
Hazardous Decomposition Products:CO, CO*2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W ALL FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MASTERSOL
CAGE:9W057
CAGE:9W057
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM RICINOLEATE
CAS:7492-30-0
RTECS #:VJ3450000
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Other REC Limits:400 PPM
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:2-PHENYLPHENOL (SARA III)
CAS:90-43-7
RTECS #:DV5775000
Ingred Name:TERTIARY-AMYL PHENOL (P-TERT AMYLPHENOL)
CAS:80-46-6
RTECS #:SM6825000
Ingred Name:INERT INGREDIENTS (TYPE NOT SPECIFIED)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IF MATERIAL IS RUBBED ON, CAN
CAUSE IRRITATION & SLIGHT RASH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: IF MATERIAL IS RUBBED ON, CAN CAUSE
IRRITATION & SLIGHT RASH.
Medical Cond Aggravated by Exposure:RASH
======================= First Aid Measures =======================
First Aid:SKIN: USE BAKING SODA & SOAP SUDS. USE SODIUM BICARBONATE &
OLIVE OIL. CALL PHYSICIAN. HOSPITALIZE FOR FURTHER TREATMENT IF
NECESSARY.
===================== Fire Fighting Measures =====================
Flash Point:MODERATE
Lower Limits:MODERATE
Extinguishing Media:REGULAR FIRE EXTINGUISHERS
Fire Fighting Procedures:REGULAR
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE AREA W/SOFT CLOTH & PAPER NAPKIN.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE NEAR OPEN FLAME. FOLLOW
DIRECTIONS ON EACH CONTAINER. USE IN NORMAL AREAS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMAL VENTILATION.
Ventilation:LOCAL EXHAUST: NORMAL OFFICE EXPOSURE.
Other Protective Equipment:NORMAL
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:COMPLETE
Appearance and Odor:BLUE COLOR, SLIGHT PERFUME ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:OPEN FLAME
Hazardous Decomposition Products:NONE
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:M-1, ASC MASKANTS
CAGE:3A367
CAGE:3A367
============= Composition/Information on Ingredients =============
Ingred Name:NICKEL (SARA III). LD50: (ORAL,RAT) 9000 MG/KG.
CAS:7440-02-0
RTECS #:QR5950000
OSHA PEL:1 MG/M3
ACGIH TLV:0.05 MG/M3
Ingred Name:ALUMINUM (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
OSHA PEL:15MG/M3 DUST/5 FUME
ACGIH TLV:10MG/M3 DUST/5 FUME
Ingred Name:CHROMIUM (SARA III)
CAS:7440-47-3
RTECS #:GB4200000
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ALUMINUM OXIDE
CAS:1344-28-1
RTECS #:BD1200000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:NICKEL OXIDE. LD50: (ORAL,RAT) 5000 MG/KG.
CAS:1313-99-1
RTECS #:QR8400000
Ingred Name:CHROMIUM OXIDE
CAS:1308-38-9
RTECS #:GB6475000
OSHA PEL:0.5 MG(CR)/M3
ACGIH TLV:0.5 MG(CR)/M3
Ingred Name:SUPP DATA: PERCHLORATES, PHOSPHORUS, SELENIUM, SULFUR, ETC.
UNDER SPECIAL CNDTNS, NICKEL CAN REACT WITH CO IN (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: REDUCING ATMOSPHERES TO FORM NICKEL CARBONYL, NI
(CO*4), AN EXTEMELY TOXIC GAS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL: AIRBORNE NICKEL POWDER AT CONC
FIFTEEN TIMES THE PEL IRRITATED THE RESP TRACT IN RODENTS.
INHALATIONS OF NICKEL OXIDE IMPAIRED LONG-TERM LUNG CLEARANCE IN
RATS AND AT CONCENTRATIONS FIFTY TIMES THE PEL, PRODUCED
PNEUMOCONIOSIS IN HAMSTERS. SKIN: RPTD CONTACT W/METALLIC NICKEL
CAN CAUSE NICKEL (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NICKEL :IARC GROUP 2B;NTP GROUP 2
Effects of Overexposure:HLTH HAZ: SENSIT RESULTING IN ALLERGIC SKIN
RASHES. NICKEL POWDER & NICKEL OXIDE HAVE CAUSED TUMORS AT SITE OF
INJECTION IN RODENTS. HOWEVER, STUDIES OF NICKEL-CNTNING PROSTHESES
DO NOT SUGGEST A SIGN IFICANT RISK HUMANS. INGEST: NICKEL METAL &
NICKEL OXIDE HAVE LOW ORAL TOX.
Medical Cond Aggravated by Exposure:SENSITIZED INDIVIDUALS MAY
EXPERIENCE AN ALLERGIC SKIN REACTION.
======================= First Aid Measures =======================
First Aid:SKIN: SEEK MED ATTN. CLEANSE WOUNDS THORO TO REMOVE ANY
NICKEL PARTICLES. IF EXPOS TO NICKEL CARBONYL IS SUSPECTED, CONTACT
MD IMMED. EYES: IMMED FLUSH WITH POTABLE WATER FOR A 15 MINUTES.
SEE MD (FPN). INGEST: GET MD IMMEDIATELY. INHAL: REMOVE TO FRESH
AIR. SUPPORT BREATHING(GIVE O*2/ARTF RESP).
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:DRY CHEMICAL (CLASS D).
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT A FIRE/EXPLOS HAZARD BY ITSELF, BUT
METAL POWDERS HEAT TREATED IN REDUCING ATMOSPHERES MAY BECOME
PYROPHORIC.
================== Accidental Release Measures ==================
Spill Release Procedures:COLLECT SPILL BY WET SWEEPING/BY VACUUMING
W/VACUUM EXHST PASSING THRU A HIGH EFFICIENCY PARTICULATE ARRESTING
(HEPA) FILTER IF EXHST IS DISCHARGED INTO WORKPLACE. WEAR APPROP
NIOSH/MSHA APPRVD RESPS IF COLLECTION & DISP OF SPILLS IS
LIKELY(SUPPDATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT INHAL PWDR. KEEP CNTNR CLSD
WHEN NOT IN USE. VENT IS NORMALLY REQD WHEN HNDLG/USING THIS PROD
TO KEEP EXPOS TO AIRBORNE NICKEL BELOW(SUPP DATA)
Other Precautions:DO NOT STORE NEAR ACIDS/REACT SUBS. LIKE OTHER
METALS, NICKEL CAN REACT W/ACIDS TO LIBERATE HYDROGEN GAS WHICH CAN
FORM EXPLOS MIX IN AIR. LIKE OTHER METAL PWDRS, NICKEL PWDR CAN
REACT EXPLO/INCANDESC ENTLY W/SUBSTANCES SUCH AS (SUPP DATA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION ALONE CANNOT CONTROL EXPOSURE
BELOW THE PEL, USE NIOSH/MSHA APPROVED RESPIRATOR SELECTED
ACCORDING TO OSHA 29 CFR. 1910.134.
Ventilation:VENT IS NORMALLY REQD WHEN HNDLG/USING PROD TO KEEP EXPOS
TO AIRBORNE NI <PEL. MAINT AIRBORNE NI LVLS AS LOW AS POSS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH SKIN THOROUGHLY AFTER HANDLING. LAUNDER
Supplemental Safety and Health
SPILL PROC: TO CAUSE CONC OF AIRBORNE NICKEL TO EXCEED PEL. HNDLG/STOR:
THE PEL. IF VENT ALONE CANNOT SO CONTROL EXPOS, USE NIOSH/MSHA
APPRVD RESPS SELECTED ACCORDING TO OSHA 29 CFR 1910.134. MAINTAIN
AIRBORNE NICKEL LEVELS AS LOW AS POSSIBLE. AVOID RPTD SKIN CONTACT.
OTHER PRECS: AMMONIUM NITRATE, (ING 7)
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:8.9 (H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:FINE GREY POWDER, ODORLESS (M-8G HAS GREEN TINT)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTS WITH MINERAL ACIDS TO LIBERATE HYDROGEN.
Stability Condition to Avoid:POWDERED MATERIAL CAN REACT WITH CO UNDER
REDUCING CONDITIONS TO FORM NI(CO)*4.
Hazardous Decomposition Products:EVOLVED HYDROGEN MAY BECOME EXPLOSIVE
HAZARD.
==================== Disposal Considerations ====================
Waste Disposal Methods:SHOULD WASTE DISPOSAL BE DEEMED NECESSARY FOLLOW
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EXTRA PURPOSE GREASE, SA8219062
Preparer's Name:JOHN R WILSON
CAGE:JO171
CAGE:99147
CAGE:JO171
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN AND EYE IRRITATION.
GASTROINTESTINAL IRRITATION IF INGESTED. NO DATA AVAILABLE
REGARDING ACUTE TOXICOLOGICAL PROPERTIES. HEALTH RISKS AND SYMPTOMS
OF EXPOSURE: INHALATION:PRODUCT IS NOT EXPECTED TO BE AN
INHALATION HAZARD. IF DISCOMFORT OCCURS REMOVE EXPOSED PERSON TO
FRESH AIR. SKIN OR EYE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: CONTACT:IRRITATION MAY OCCUR WITH
PROLONGED OR REPEATED CONTACT. SKIN ASBBORPTION:PRODUCT IS NOT
EXPECTED TO BE ABSORBED THROUGH THE SKIN. INGESTION:MAY CAUSE
GASTRIONNTESTINAL IRRITATION.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN OR EYE CONDITIONS
COULD BE AGGRAVATED BY EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH LARGE QUANTITIES OF WATER FOR AT
LEAST 15 MINUTES. CONTACT A PHYSICIAN. SKIN: REMOVE EXCESS WITH
CLOTH OR PAPER. WASH THROUGHLY WITH SOAP AND WATER. INHALATION:
REMOVE PER SON TO FRESH AIR IF DISCOMFORT IS EXPERIENCED WHILE
HANDLING HOT PRODUCT. INGESTION: CONTACT A PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>356F,>180C
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER FOG, OTHER.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . DO NOT USE WATER EXCEPT AS FOG.
Unusual Fire/Explosion Hazard:DENSE SMOKE. DO NOT USE WATER EXCEPT AS
FOG.
================== Accidental Release Measures ==================
Spill Release Procedures:TRANSFER BULK MATERIAL TO ANOTHER CONTAINER.
ABSORB REMAINING MATERIAL WITH SAND, EARTH, VERMICULITE, ETC.
COLLECT WASTE AND DISPOSE IN ACCORD WITH LOCAL, STATE, AND FEDERAL
REGULATIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE CONTAINERS IN COOL DRY LOCATION,
AWAY FROM EXCESSIVE HEAT, SPARKS, AND FLAME. KEEP CONTAINERS CLOSED
UNTIL READY FOR USE.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED. NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NOT NORMALLY REQUIRED.
Other Protective Equipment:ANSI APPRVD EMER EYE WASH & DELUGE SHOWER.
NOT NORM REQD. CHEM RESIST APRON MAY BE DESIRABLE IN CERTAIN
(SUPDAT)
Work Hygienic Practices:NO SPECIAL REQUIREMENTS. USE GOOD PERSONAL
HYGIENE PRACTICES.
Supplemental Safety and Health
OTHER PROT EQPT:SITUATIONS.
================== Physical/Chemical Properties ==================
Spec Gravity:0.8 (H*2O = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GREASE, SEMI-SOLID, MINERAL OIL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS: HYDROGEN PEROXIDE, CHROMIC ACID,
BROMINE.
Stability Condition to Avoid:OXIDIZING CONDITIONS.
Hazardous Decomposition Products:ZINC OXIDE, OXIDES OF PHOSPHORUS AND
SULFUR. HYDROGEN SULFIDE. HYDROCHLORIC ACID CARBON MONOXIDE AND
CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE, AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: GS-3/E
Cage: 20772
Box: 483
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 20772
Box: 483
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: SEE INGREDIENTS 1 & 2
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: EYE CONT: CAN CAUSE MILD IRRITATION. SKIN CONT:
IRRITATION CAN OCCUR FOLLOWING PROLONGED OR REPEATED CONTACT. INHALATION:
PROCESSING VAPORS CAN POSSIBLY CAUSE IRRITATION TO UPPER RESPIRATORY TR ACT.
INGESTION: CAN CAUSE GASTROINTESTINAL IRRITATION. TOXICOLOGICAL INFO:
LUCRICANT OILS: MAY CAUSE (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: TRANSIENT IRRITATION TO EYES
AND/OR SKIN.
Medical Cond Aggravated By Exposure: A REVIEW OF AVAILABLE DATA DOES NOT
IDENTIFY ANY WORSENING OF ANY EXISTING MEDICAL CONDITIONS.
First Aid: EYE CONT: FLUSH W/PLENTY OF WATER FOR @ LST 15 MINS. IF IRRIT
DEVELOPS, CONSULT PHYS. SKIN CONT: REMOVE CONTAMD CLTHG. WASH AFFECTED AREA
W/SOAP & PLENTY OF WATER. IF IRRIT DEVELOPS, CONSULT PHYS. WAS H CONTAMD
CLTHG SEPARATELY BEFORE REUSE. INHAL: REMOVE TO FRESH AIR. IF SYMPS DEVELOP,
SEEK IMMED MED ATTN. IF NOT BRTHG, GIVE ARTF RESP. INGEST: CALL PHYS IMMED.
INDUCE VOMIT ONLY AS DIRECTED(SUPDAT)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: EVACUATION: ISOLATE HAZARD AREAS. KEEP UNNECESSARY
& UNPROTECTED PERSONNEL FROM ENTERING AREA. ELIM ALL SOURCES OF IGNIT.
CONTAINMENT: SFTY STOP DISCHARGE. CNTN MATL, AS NEC, WITH DIKE/BARRIER. STOP
M ATL FROM CONTAMINATING SOIL/FROM ENTERING
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF I/A/W APPLIC LOCAL, STATE & FEDERAL
REGS. GEN STATEMENT: FED REGS MAY APPLY TO EMPTY CNTNR. STATE AND/OR LOC REGS
MAY BE DIFFERENT. GEN REC: OF METHODS OF DISP CURRENTLY AVAIL, IT IS REC TH
AT ALTERNATIVE BE SELECTED ACCORDING
Handling And Storage Precautions: STORE IN COOL, DRY AREA AWAY FROM HEAT, IGNIT
SOURCES, & DIRECT SUNLIGHT. ALWAYS KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions: WARNING: HOT ORG CHEM VAPS/MISTS CAN SUDDENLY & W/OUT
WARNING COMBUST WHEN MIXED W/AIR. IGNIT CAN OCCUR @ TYPICAL ELEVATED TEMPS
DURING PROCESSING CNDTNS. ANY USE IN SUCH PROCESSES SHOULD BE EVALUATED
THOROUGHLY TO ENSURE SAFE
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: >400F,>204C
Extinguishing Media: SM FIRES: USE DRY CHEM, CARBON DIOXIDE, HALON, WATER
SPRAY, OR FOAM. LG FIRES: USE WATER SPRAY, FOG, OR ALCOHOL FOAM.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: MAY LIBERATE IRRITATING/TOXIC VAPS DURING
COMBUST/DECOMP. UNUSUAL FIRE & HAZ COMBUST & DECOMP PRODS: SMOKE,
SOOT, & TOXIC/IRRITATING FUMES (I.E. CO*2, (SUPDAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: AVOID BRTHG VAP AND/OR MIST. IF OCCUP EXPOS LIMITS ARE
EXCEEDED WEAR NIOSH APPRVD EQUIP. DETERM APPROP TYPE BY CONSULTING RESP MFR.
HIGH AIRBORNE CONCS MAY NECESSITATE USE OF NIOSH APPRVD SCBA/SUPPLIE D AIR
RESP. RESP PROT PROGRAMS
Ventilation: MAINTAIN AIRBORNE CONCS BELOW ESTABLISHED EXPOS LIMITS (SEE PEL
& TLV IN INGRED SECTION) BY PROVIDING ADEQ VENT.
Other Protective Equipment: ANSI APPRVD EYE WASH & DELUGE SHOWER (FP N). WEAR
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: USERS OF "L" VERSION OF SHOULD CONSULT "LR"
VERSION FOR ADDITIONAL INFORMATION (FP N). EXPLO HAZ: CO, ETC), OXIDES OF
NITROGEN. FIRST AID PROC: BY MEDICAL PERSONNEL. NOTE TO PHYS: TREATMENT SHOUL
D BE DIRECTED AT PREVENTING ABSORPTION,ADMINISTERING TO SYMPTOMS AS THEY
OCCUR, & PROVIDING SUPPORTIVE THERAPY.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
Spec Gravity: 0.85 (WATER =1)
Evaporation Rate & Reference: NOT KNOWN
Solubility in Water: INSOLUBLE
Appearance and Odor: RED LIQUID, MINERAL OIL ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HIGH TEMPERATURES.
Materials To Avoid: OXIDIZERS.
Hazardous Decomposition Products: COMBUSTION MAY PRODUCE CARBON MONOXIDE AND
CARBON DIOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: VOLATILE ORGANIC CONTENT MATERIAL: NOT DETERMINED.
=======================================================
HAZCOM Label
=======================================================
Product ID: GS-3/E
Cage: 20772
Company Name: SPECTRONICS CORP
Street: 956 BRUSH HOLLOW RD
PO Box: 483
Zipcode: 11590
Label Required IND: Y
Date Of Label Review: 06/25/1998
Status Code: C
Label Date: 06/25/1998
Origination
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE: EYE CONT: CAN CAUSE MILD IRRITATION. SKIN CONT:
IRRITATION CAN OCCUR FOLLOWING PROLONGED OR REPEATED CONTACT. INHALATION:
PROCESSING VAPORS CAN POSSIBLY CAUSE IRRITATION TO UPPER RESPIRATORY TR ACT.
INGESTION: CAN CAUSE GASTROINTESTINAL IRRITATION. TOXICOLOGICAL INFO:
LUCRICANT OILS: MAY CAUSE TRANSIENT IRRITATION TO EYES AND/OR SKIN. CHRONIC:
NONE LISTED BY MANUFACTURER.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CLEAN FRONT CONCENTRATE 0544
Preparer's Name:C.S. EMMONS
CAGE:FO657
CAGE:66750
CAGE:FO657
============= Composition/Information on Ingredients =============
Ingred Name:POVIDONE (IODINE)
CAS:25655-41-8
RTECS #:TR1579600
Fraction by Wt: 20%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 3,250 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: REVERSIBLE/SEVERE
IRRITATION. SKIN: MILD IRRITATION & STAINING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: REVERSIBLE/SEVERE IRRITATION,
MUCOSAL DAMAGE, GASTRIC LAVAGE, CIRCULATORY SHOCK, RESPIRATORY
DEPRESSION, & CONVULSION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MIN. GET MED ATTN. SKIN:
FLUSH W/WATER. GET MED ATTN. REMOVE/LAUNDER CONTAMINATED CLOTHING
BEFORE REUSE. INGESTION: DRINK LARGE QUANTITIES OF MILK, EGG
WHITES, GELA TIN SOLUTION, OR WATER. GET MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:>100C
Extinguishing Media:WATER, CO2
Fire Fighting Procedures:NOT FLAMMABLE
Unusual Fire/Explosion Hazard:MAY EMIT TOXIC FUMES OF IODINE W/HIGH
HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:NEUTRALIZE IODINE W/SODIUM THIOSULFATE OF
SODIUM SULFITE.
Neutralizing Agent:IODINE W/SODIUM THIOSULFATE
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTAMINATION OF FOOD &
FEEDSTUFF. KEEP CONTAINER CLOSED WHEN NOT IN USE. DON'T STORE <0F
OR >100F.
Other Precautions:IF DRUM IS CONTAMINATED, CANNOT BE REUSED. AVOID
CONTACT W/CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NEEDED
Ventilation:NOT NEEDED
Other Protective Equipment:RUBBER APRON
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>105C
Spec Gravity:1.37
pH:<1
Evaporation Rate & Reference:<1
Solubility in Water:COMPLETE
Appearance and Odor:DARK BROWN VISCOUS LIQUID W/IODOPHOR
Percent Volatiles by Volume:38%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALIES, REDUCING AGENTS
Stability Condition to Avoid:HEAT, TEMPS >100F & <0F
Hazardous Decomposition Products:TOXIC FUMES OF IODINE
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH TO SEWER IF IN ACCORDANCE W/LOCAL, STATE,
& FEDERAL REGULATIONS. COMPLETELY EMPTY LINER, THEN DISPOSE OF
LINER IN A SANITARY LANDFILL OR BY INCINERATION. CONSULT STATE &
LOCAL AUTHORITIES. IF DR UM IS CONTAMINATED DISPOSE OF IN SAME
MANNER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TYPE 842,3M BRAND"VHS"IMAGING POWDER
CAGE:76381
CAGE:76381
============= Composition/Information on Ingredients =============
Ingred Name:EPICHLOROHYDRIN/BISPHENOL A TYPE EPOXY RESIN
Fraction by Wt: <50%
Ingred Name:MAGNETITE(MOSTLY FE*3O*4)CAS#1309-37-1(TLV AS FE)
Fraction by Wt: >50%
ACGIH TLV:5.0 MG/CUM
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: <5%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192
Ingred Name:SILICA, AMORPHOUS, DUST
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: <2%
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3; 8990
===================== Hazards Identification =====================
Effects of Overexposure:SLIGHT IRRITANT TO EYES ANDSKIN,INHALATION
HAZARDS ARE ALSO LOW.THE POWDER IS NONTOXIC WHEN INTESTD.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH EYES WITH PLENTY OF WATER.CALL A PHYSICIAN
SKIN:WASH AFFECTED AREAS WITH SOAPY WATER INHALATION:REMOVE PERSON
TO FRESH AIR INGESTION:INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Lower Limits:UNK
Upper Limits:UNK
Extinguishing Media:POWDER,ALCOHOL FOAM,LARGE AMTS OF WATER, HALONS.
Fire Fighting Procedures:NOT SPECIFIED BY THE MFGR
Unusual Fire/Explosion Hazard:CLASS A COMBUSTIBLE
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP OR VACUUM UP SPILLED MATERIAL CLEAN
UP RESIDUE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL DRY PLACE.
Other Precautions:AVOID EYE CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED
Ventilation:GOOG GENERAL VENTILATION IS ADEQUATE
Other Protective Equipment:NOT SPECIFIED BY THE MFGR
Supplemental Safety and Health
MSDS NOT SIGNED,MSDS DATED 4/81.
================== Physical/Chemical Properties ==================
HCC:V7
Vapor Pres:UNK
Vapor Density:UNKN
Spec Gravity:UNKNOW
Solubility in Water:NIL
Appearance and Odor:FINE BLACK POWDER
Percent Volatiles by Volume:0.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
UNK
Stability Condition to Avoid:NOT SPECIFIED BY THE MFGR.
Hazardous Decomposition Products:CO, ALDEHYDE,ACIDS.
Conditions to Avoid Polymerization:RESIN CAN REACT WITH STROG OXIDIZING
AGENT ON MINRLACID
==================== Disposal Considerations ====================
Waste Disposal Methods:MAY BE SANITARY LANDFILL OR INCINERATE PROPERLY
IN ACCOREANCE WITH ALL FED,STATE AND LOCAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:ARDROX BIOPEN NQ-2 DEVELOPER
Preparer's Name:SHEREE L.KINZEL
CAGE:23373
CAGE:23373
============= Composition/Information on Ingredients =============
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: >90.0%
Other REC Limits:NONE SPECIFIED
OSHA PEL:350 PPM/450 STEL
ACGIH TLV:350 PPM/450STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:SEC-BUTYL ALCOHOL (SARA III)
CAS:78-92-2
RTECS #:EO1750000
Fraction by Wt: <5.0%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM
ACGIH TLV:100 PPM; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATION OF
EYES,SKIN,RESPIRATORY OR G.I.TRACTS;CNS EFFECTS LIKE
HEADACHE,DIZZINESS,NAUSEA AND VOMITING. REDNESS/TEAR OR BURNS OF
EYES/SKIN POSSIBLE.CHRONIC:DRYING OF SKIN,DEFATTING OR DERMATI TIS.
Explanation of Carcinogenicity:DATA PER MSDS
Effects of Overexposure:MAY CAUSE IRRITATION OF EYES,SKIN,RESPIRATORY
OR G.I.TRACTS;MAY CAUSE HEADACHE,DIZZINESS,NAUSEA,VOMITING OR GI
TRACT DISTURBANCES POSSIBLE.BURNS OR REDNESS OF EYES/CRACKING OR
DRYNESS OF SKIN.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
FOR 15 MINUTES HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION.
SKIN:REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER. IF
IRRITATION PERSISTS, GET MEDICAL ADVICE. INGESTION:DO NOT INDUCE
VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET IMMEDIATE
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F,>93C
Autoignition Temp:Autoignition Temp Text:998F
Extinguishing Media:WATER SPRAY,DRY CHEMICAL,CO*2 AND WATER FOG
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:CONTAINERS MAY RUPTURE DUE TO EXTREME
HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;REMOVE ALL
IGNITION SOURCES. CONTAIN FREE MATERIAL IF POSSIBLE;USE SUITABLE
INERT ABSORBENT MATERIAL AND RECOVER FOR PROPER DISPOSAL IN AN
APPROVED CONTAINER.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. KEEP AWAY
FROM NAKED FLAMES.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE MIST. AVOID
PROLONGED OR REPEATED BREATHING OF VAPOR. AVOID CONTACT WITH EYES.
USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR AS REQUIRED
IF ABOVE PEL/TLV OR SCBA IN AN ENCLOSED AREA.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER,WORK
CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS.
================== Physical/Chemical Properties ==================
HCC:T4
Boiling Pt:B.P. Text:165F,74C
Vapor Pres:100
Vapor Density:4.5
Spec Gravity:1.29
Evaporation Rate & Reference:0.35 (ETHER=1)
Solubility in Water:SLIGHT
Appearance and Odor:WHITE POWDER SUSPENDED IN COLORLESS
LIQUID,CHARACTERISTIC ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES,ALKALI METALS.
Stability Condition to Avoid:HIGH TEMPERATURES ,SPARKS AND NAKED
FLAMES.
Hazardous Decomposition Products:HYDROGEN CHLORIDE ;VERY SMALL AMOUNT
OF PHOSGENE AND CHLORINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES.DISPOSAL MUST BE MADE
IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SILICONE FORM-A-GASKET ADHESIVE SEALANT BLU
Preparer's Name:STEPHEN REPETTO
CAGE:62377
CAGE:62377
============= Composition/Information on Ingredients =============
Ingred Name:POLYDIMETHYL SILOXANE; (POLY(DIMETHYLSILOXANE))
CAS:9016-00-6
RTECS #:TQ2690000
Fraction by Wt: 80-85%
Ingred Name:POLYACETOXY SILANE
Fraction by Wt: <5%
Ingred Name:SILICA, CRYSTALLINE - FUSED; (SILICON DIOXIDE)
CAS:60676-86-0
RTECS #:VV7320000
Fraction by Wt: 10-15%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:PIGMENT
Fraction by Wt: <5%
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL) 3300 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SILICON DIOXIDE DUST HAS BEEN SHOWN TO
CAUSE ADVERSE PULMONARY EFFECTS ON INHALATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:ACETIC ACID PRODUCED DURING CURE IRRITATES
EYES, NOSE, AND THROAT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST: DO NOT INDUCE VOMITING. KEEP INDIVIDUAL CALM. OBTAIN
MEDICAL ATTENTION. INHAL: REMOVE TO FRESH AIR. TREAT
SYMPTOMATICALLY. SKIN: WIPE OFF GEL WITH PAPER TOWEL OR CLOTH. WASH
EXPOSED AREA WITH SOAP AND WATER. EYE: FLUSH FOR AT LEAST15
MINUTES WITH WATER. OBTAIN MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>200F,>93C
Extinguishing Media:CO*2, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE OR SCRAPE UP SPILLED MATERIAL. MAINTAIN
GOOD VENTILATION FOR LARGE SPILLS. PLACE SCRAP MATERIAL IN A
WELL-VENTILATED PLACE AND ALLOW TO CURE TO RUBBER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A DRY AREA. KEEP CONTAINERS
CLOSED WHEN NOT IN USE. AVOID SKIN AND EYE CONTACT. AVOID BREATHING
VAPORS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:PROVIDE LOCAL VENTILATION FOR PROLONGED USE IN A CONFINED
AREA.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Vapor Pres:<10 @ 70F
Spec Gravity:1.04 @ 70F
Solubility in Water:POLYMERIZED
Appearance and Odor:BLUE GEL WITH ACETIC ACID ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
POLYMERIZED BY CONTACT WITH MOISTURE. ACETIC ACID LIBERATED.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:ACETIC ACID, FORMALDEHYDE, SILICA
MIST.
==================== Disposal Considerations ====================
Waste Disposal Methods:CURED RUBBER SCRAP CAN BE LANDFILLED OR
INCINERATED FOLLOWING EPA, FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TWO CYCLE OIL, TYPE V, CLASS 4, TC-W
Preparer's Name:ANDREW B. WHITLOCK
CAGE:25705
CAGE:25705
CAGE:1HJ95
CAGE:62986
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENT DE-WAXED HEAVY PARAFFINIC PETROLEUM DISTILLATES
CAS:64742-65-0
Minumum % Wt:50.
Maxumum % Wt:65.
OSHA PEL:5 MG/CUM AS OIL MIST
ACGIH TLV:5 MG/CUM AS OIL MIST
Ingred Name:KEROSENE
CAS:8008-20-6
RTECS #:OA5500000
Minumum % Wt:20.
Maxumum % Wt:35.
Other REC Limits:100 PPM
Ingred Name:ALIPHATIC CARBOXYLIC ACID AMIDE
Minumum % Wt:10.
Maxumum % Wt:20.
Ingred Name:HYDROTREATED C25 BRIGHT STOCK BASED LUBRICATING OIL
CAS:72623-83-7
Minumum % Wt:1.
Maxumum % Wt:10.
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: SKIN & EYE IRRITATION;
DROWSINESS FOR HIGH VAPOR/MIST CONCENTRATION. CHRONIC: HEALTH
STUDIES HAVE SHOWN THAT MANY PETROL. HYDROCARBONS & SYNTHETIC
LUBRICANTS POSE HUMAN HEALTH RISKS WHICH MAY VARY FROM PERSON TO
PERSON. AS A PRECAUTION,EXPOSURE TO LIQUIDS,MISTS OR FUMES SHOULD
BE MINIMIZED.
Effects of Overexposure:EYE/SKIN: IRRITATES; INHAL: MAY CAUSE
DROWSINESS, NARCOSIS, & UNCONSCIOUSNESS.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/RUNNING WATER FOR 15 MIN. HOLDING LID OPEN TO
EXPOSE AS MUCH SURFACE AS POSSIBLE. GET MED. ATTN; SKIN: REMOVE
CONTAMIN. CLOTHING & SHOES. WASH EXPOSED AREA W/MILD SOAP & WATER,
APPLY SKINCREAM FOR IRRITATION; INHAL: REMOVE TOFRESH AIR
IMMEDIATELY. GIVE O2/CPR AS SITUATION DICTATES. GET MED. ATTN.;
INGEST: DO NOT INDUCE VOMITING -GET MEDICAL ATTN. IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:=54.4C, 130.F
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY. CONTAIN RUNOFF.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES. DIKE & TAKE-UP
W/INERT ABSORBENT MATERIAL, SUCH AS EARTH OR FLOOR DRY. ENSURE
ADEQUATE VENTILATION.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN MATERIAL
NOT IN USE. DO NOT STORE OR HANDLE NEAR HEAT,SPARKS,FLAME,OR STRONG
OXIDIZERS. MAINTAIN ADEQUATE VENTILATION!!
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED IN NORMAL USE OF
PRODUCT.NIOSH/MSHA APPRVD. RESPIRATOR SHOULD BE USED AT ANY TIME
WHEN VAPOR CONCENTRATIONS EXCEED ESTABLISHED STANDARDS; UP TO 50
MG/CUM:ANY SUPPLIED-AIR RESPIRATOR/ANY SELF-CONTND BRTHNG APP/HI
EFF.FLTR-AIR
Ventilation:AS REQUIRED TO MAINTAIN AIR CONTAMINANTS LEVEL BELOW
ESTABL. STANDARDS; LOCAL EXHAUST @ >60 FPM.
Other Protective Equipment:NONE REQUIRED IN NORMAL USE.
Work Hygienic Practices:BASIC GOOD HOUSEKEEPING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
Spec Gravity:0.87
Solubility in Water:INSOLUBLE
Appearance and Odor:DARK, REDDISH PURPLE, PETROLEUM ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS LIKE CHLORINE & CONCENTRATED OXYGEN.
Stability Condition to Avoid:EXTREMELY HIGH TEMPERATURES, OPEN FLAMES
AND SPARKS.
Hazardous Decomposition Products:VARIOUS OXIDES OF CARBON, KETONES,
ALDEHYDES, COMBUSTION PRODUCTS OF NITROGEN & SULFUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY W/ ALL APPLICABLE FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BARIUM ACETATE, I-20
CAGE:84898
CAGE:84898
CAGE:8Y898
============= Composition/Information on Ingredients =============
Ingred Name:ACETIC ACID, BARIUM SALT; (BARIUM ACETATE)
CAS:543-80-6
RTECS #:AF4550000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUP DAT: OF WATER. CONT POIS CTL CTR IMMED IF NEC. GET MED
ATTN IF NEC. IF PATIENT IS VOMIT, WATCH CLOSELY (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2: TO MAKE SURE AIRWAY DOES NOT BECOME OBSTRUCTED BY
VOMIT.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: PROD MAY NOT BE USED AS DRUGS, COSMETICS,
AGRICULTURAL/PESTICIDAL PRODS, FOOD ADDITIVES/HOUSEHOLD CHEMICALS.
RTECS #:9999999ZZ
Ingred Name:HYGIENE PRACT: CLOTHING UNTIL ABSOLUTELY FREE OF ALL
CHEMICAL ODORS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT): 921 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CAN CAUSE EYE & SKIN IRRIT.
RPTD EXPOS TO VAPS &/DUST CAN CAUSE EYE INJURY. CAN BE FATAL IF
ABSORBED THRU SKIN/INHALED/SWALLOWED. DUST &/VAPS CAN CAUSE IRRIT
TO RESP TRACT. CAN CAUSE CARDIOVASC ULAR SYS & NERV SYS INJURY, GI
DISTURB.POSS CHOLINESTERASE INHIBITOR. MAY CAUSE SEIZURES, NAUS,
(EFTS OF OVEREXPOSURE)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: VOMIT, AIRWAY OBSTRUCTION &/INCR MUC
SECRETIONS IN LUNGS. INGEST MAY CAUSE DIARR. CHRONIC: NONE
SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:ANTIDOTE IS SUBSTANCE INTENDED TO COUNTERACT EFT OF POIS. IT
SHOULD BE ADMIN ONLY BY MD/TRAINED EMER PERS. MED ADVICE CAN BE
OBTAINED FROM POIS CTL CTR. EYES: FLUSH CONTINOUSLY W/WATER FOR AT
LEAST 15 MIN. SKIN: FLUSH W/WATER FOR 15-20 MIN. IF NO BURNS HAVE
OCCURRED, USE SOAP & WATER TO CLEANSE SKIN. INHAL: REMOVE TO FRESH
AIR. ADMIN OXYGEN IF DFCLT BRTHG. IF BRTHG HAS STOPPED, ADMIN (SUP
DAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:USE CARBON DIOXIDE OR DRY CHEMICAL POWDER. DO NOT
USE WATER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR APPROPRIATE OSHA-REGULATED
EQUIPMENT. VENTILATE AREA. SWEEP UP AND PLACE IN AN APPROPRIATE
CONTAINER. HOLD FOR DISPOSAL. WASH CONTAMINATED SURFACES TO REMOVE
ANY RESIDUES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:ALL CHEM SHOULD BE CONSIDERED HAZ.
AVOID DIRECT PHYSICAL CONT! THIS CHEM SHOULD BE HANDLED ONLY IN
HOOD. USE APPROP OSHA/MSMA APPRVD SFTY EQUIP.
Other Precautions:AVOID CONT W/SKIN, EYES & CLTHG. KEEP TIGHTLY CLSD &
STORE IN COOL DRY PLACE. STORE ONLY W/COMPATIBLE CHEM. PERS NOT
SPECIFICALLY & PROPERLY TRAINED SHOULD NOT HANDLE THIS CHEM/ITS
CONTR. THIS PROD IS FURNISHED FOR LAB USE ONLY! (ING 4)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:THIS CHEMICAL SHOULD BE HANDLED ONLY IN A HOOD.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:CONTACT LENSES SHOULD NOT BE WORN IN THE LAB.
REMOVE AND WASH CONTAMINATED CLOTHING. DO NOT WEAR SHOES OR (ING 5)
Supplemental Safety and Health
MATLS TO AVOID: ALLOYS AS CONTRS. FIRST AID PROC: ARTF RESP. IF SIGNS
OF SHOCK, KEEP WARM & QUIET. GET MED ATTN IF NEC. IF PATIENT IN
CARD ARREST ADMIN CPR. CONTINUE LIFE SUPPORTING MEASURES UNTIL MED
ASSIST HAS ARRIVED. INGEST: DO NOT ADMIN LIQS/INDUCE VOMIT TO
UNCON/CONVL PERS. IF SWALLOWED DRINK 1-2 GLASSES (ING 2)
================== Physical/Chemical Properties ==================
Spec Gravity:2.468
Solubility in Water:SOLUBLE
Appearance and Odor:COLORLESS CRYSTALLINE SOLID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTS W/ACID HALIDES & ANHYDRIDES, PHOSPHORUS HALIDES, THIONYL
CHLORIDE. DO NOT USE MAGNESIUM/ALUMINUM/THEIR (SUP DAT)
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:DECOMPOSITION LIBERATES TOXIC FUMES.
DECOMPOSITION PRODUCTS ARE FLAMMABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN AN APPROVED LANDFILL. DISPOSE OF
IN ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LOGESOL II POWDER SYSTEM CLEANER, L80600006
CAGE:21297
CAGE:21297
============= Composition/Information on Ingredients =============
Ingred Name:CITRIC ACID
CAS:77-92-9
RTECS #:GE7350000
Fraction by Wt: 40-70%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POTASSIUM PEROXYSULFATE (MFR CAS #70693-62-8)
CAS:10361-76-9
RTECS #:SE1000000
Fraction by Wt: 40-70%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUND: 0 LBS/GAL
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT: MAY CAUSE IRRITATION AND
DAMAGE TO TISSUE. SKIN CONTACT: MAY CAUSE IRRITATION. INGESTION:
MAY CAUSE IRRITATION OR CORROSION TO DIGESTIVE TRACT. INHALATION:
MAY CAUSE IRRITATION TO NASAL M UCOUS MEMBRANES OR RESPIRATORY
TRACT.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NO MEDICAL CONDITIONS KNOWN TO BE
AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYES: IRRIGATE WITH WATER FOR AT LEAST 15 MINUTES. CONTACT
MD. SKIN: WASH WITH COPIOUS AMOUNTS OF WATER AND SOAP FOR AT LEAST
15 MINUTES. INGESTION: ADMINISTER 2-3 GLASSES OF WATER OR MILK.
NEVER ADMI NISTER ANYTHING TO AN UNCONSCIOUS PERSON. CONTACT MD
IMMEDIATELY. INHALATION: REMOVE TO FRESH AIR. IF ADVERSE SYMPTOMS
PERSIST, CONTACT MD.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:ANY APPLICABLE TO THE PRIMARY CAUSE OF FIRE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . EVACUATE PERSONNEL TO A SAFE AREA.
Unusual Fire/Explosion Hazard:GRINDING OR EXCESSIVE MIXING MAY IGNITE
THE MATERIAL.
================== Accidental Release Measures ==================
Spill Release Procedures:USE APPROPRIATE PROTECTIVE EQUIPMENT. SWEEP
THE SPILL INTO A WASTE CONTAINER. PREVENT POWDER FROM ENTERING
SEWERS OR WATERWAYS. DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE
AND LOCAL REGULATIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A WELL VENT AREA. KEEP CNTNR
TIGHTLY CAPPED WHEN NOT IN USE. DO NOT STORE FOOD/DRINK/TOBACCO IN
AREAS WHERE CONTAM COULD OCCUR W/THIS PROD.
Other Precautions:AVOID BREATHING DUSTS. AVOID CONTACT WITH EYES, SKIN
AND CLOTHING. DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF
CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR POORLY VENTILATED AREAS A NIOSH/MSHA
APPROVED CARTRIDGE RESPIRATOR IS RECOMMENDED.
Ventilation:TEN ROOM VOLUMES PER HOUR IS RECOMMENDED UNDER NORMAL
CONDITIONS.
Other Protective Equipment:LAB COAT, DUST MASK AND EYE WASH STATION.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
EYE PROT: AND FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:DECOMPOSES
Solubility in Water:COMPLETELY SOLUBLE
Appearance and Odor:FREE FLOWING WHITE POWDER.
Percent Volatiles by Volume:NONVOL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HEAVY METAL SALTS, NICKEL AND COPPER.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:RELEASE OF OXYGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE TO SEWER REQUIRES THE APPROVAL OF
PERMITTING AUTHORITY AND MAY REQUIRE PRETREATMENT. TREATMENT,
STORAGE, TRANSPORATION AND DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULA TIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:95605 EC BROTH W/DURHAM TUBE
CAGE:05545
CAGE:05545
CAGE:15481
============= Composition/Information on Ingredients =============
Ingred Name:PREPARED TUBED AND MYCOFLASK MEDIA-CLASSIFIED/SELECTIVE
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS PRODUCT CONTAINS NO HAZARDOUS
MATERIALS AS DEFINED BY THE OSHA HAZARD COMMUNICATION STANDARD. IN
THE EVENT OF A SPILL/ACCIDENT INVOLVING THIS MATERIAL, GOOD
PERSONAL HYGIENE SHOULD BE PRACTICED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:THIS PRODUCT CONTAINS NO HAZARDOUS MATERIALS AS
DEFINED BY THE OSHA HAZARD COMMUNICATION STANDARD. IN THE EVENT OF
A SPILL/ACCIDENT INVOLVING THIS MATERIAL, GOOD PERSONAL HYGIENE
SHOULD BE PRACTICED.
======================= First Aid Measures =======================
First Aid:OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATERSPRAY
Fire Fighting Procedures:IF PRODUCT BECOMES INVOLVED IN A FIRE
SITUATION, EXTINUISHING MEDIA FOR SURROUNDING MATERIAL SHOULD BE
APPROPRIATE.
Unusual Fire/Explosion Hazard:PRODUCT WILL NOT BURN.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PAPER TOWELS TO PICK UP LIQUID &/GELLED
MATERIAL. WASH AREA W/SOAP & WATER AFTER CLEANUP IS COMPLETE.
OBSERVE ASEPTIC TECHNIQUES & ESTABLISHED PRECAUTIONS AGAINST
MICROBIOLOGICAL HAZARDS THROUGHOU T ALL PROCEDURES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER NORMAL PRODUCT USAGE.
Ventilation:NOT REQUIRED UNDER NORMAL PRODUCT USAGE.
Other Protective Equipment:NOT REQUIRED UNDER NORMAL PRODUCT USAGE.
Work Hygienic Practices:GOOD PERSONAL HYGIENE SHOULD BE PRACTICED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Appearance and Odor:CLEAR TO TRACE HAZY LIQUID OF VARYING COLORS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:AFTER USE, PREPARED TUBED MEDIA, SPECIMEN
CONTAINERS & OTHER CONTAMINATED MATERIALS MUST BE STERILIZED BY
AUTOCLAVING. DIRECTIONS FOR USE MUST BE READ & FOLLOWED CAREFULLY.
DISPOSE OF IAW/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:C 600
CAGE:GOCAR
CAGE:GOCAR
============= Composition/Information on Ingredients =============
Ingred Name:TANTALUM
CAS:7440-25-7
RTECS #:WW5505000
Fraction by Wt: 0-5%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:COLUMBIUM, NIOBIUM *93-1*
CAS:7440-03-1
Fraction by Wt: 3-4%
Other REC Limits:5 MG/CUM
Ingred Name:TUNGSTEN (INSOLUBLE), WOLFRAM
CAS:7440-33-7
RTECS #:YO7175000
Fraction by Wt: 0-5%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:ALUMINUM (POWDER)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 0-1.7%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: 4-22%
OSHA PEL:10 MG/CUM FUME
ACGIH TLV:5 MG/CUM FUME
Ingred Name:CHROMIUM METAL, CHROMIUM, CHROME (SUSPECTED A1 HUMAN
CARCINOGEN BY IARC, NTP & ACGIH)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 14-25%
OSHA PEL:1 MG/CUM (CEILING)
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:NICKEL (SOLUBLE) (SUSPECTED HUMAN CARCINOGEN BY NTP, IARC,
ACGIH) INTENDED CHANGE (IC)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 38-72%
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/CUM
ACGIH TLV:0.05 MG/CUM IC
Ingred Name:MANGANESE, MN COMPOUNDS
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 0-2%
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:MOLYBDENUM (SOLUBLE COMPOUND), LEAD MOLYBDATE
CAS:7439-98-7
RTECS #:QA4680000
Fraction by Wt: 2.5-17%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9293
Ingred Name:COPPER (DUST & MIST), BRONZE POWDER
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 0-3%
Other REC Limits:1 MG(CU)/M3 (DUST)
OSHA PEL:0.1 MG(CU)/M3 (FUME)
ACGIH TLV:0.2 MG/M3 (FUME)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:COBALT
CAS:7440-48-4
RTECS #:GF8750000
Fraction by Wt: 0-2.5%
Other REC Limits:0.05 PPM
OSHA PEL:0.1 MG/M3;AS CO
ACGIH TLV:0.05 MG/M3;DUST 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:NO TOXIC EFFECTS EXPECTED FROM INERT
FORM. EXPOSURE TO FUMES OR DUSTS GENERATED DURING HEATING, CUTTING,
BRAZING OR WELDING MAY CAUSE ADVERSE HEALTH EFFECTS. INHALATION:
IRRITATION OF NOSE & THROAT. M ETAL FUME FEVER. EYES: IRRITATION.
INGESTION: IRRITATION OF THE MOUTH & THROAT.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:INHALATION: PNEUMONITIS, SIDEROSIS. CNS
INVOLVEMENT. INTERSTITIAL PNEUMONITIS & SENSITIZATION. NODULAR
PULMONARY DISEASE. SKIN: DERMATITIS DUE TO SENSITIZATION.
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP OR MILD DETERGENT & WATER FOR 5 MINS. EYES:
WASH W/PLENTY OF WATER FOR 15 MINS. INHALATION/INGESTION: OBTAIN
MEDICAL ATTENTION IN ALL CASES.
======================Handling and Storage ======================
Handling and Storage Precautions:DURING WELDING, PRECAUTIONS SHOULD BE
TAKEN FOR AIRBORNE CONTAMINANTS & NOXIOUS GASES FROM THE WELDING
PROCESS OR COMPONENTS OF THE WELDING ROD.
Other Precautions:ARC & SPARKS GENERATED WHEN WELDING W/THIS PRODUCT
COULD BE A SOURCE OF IGNITION FOR COMBUSTIBLE & FLAMMABLE
MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A PROPERLY FITTED NIOSH APPROVED DUST-FUME
RESPIRATOR DURING WELDING OR BURNING.
Ventilation:RECOMMENDED TO KEEP BELOW TLV
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
SOME CONSTITUENTS POSE MORE POTENTIAL HAZARDS THAN OTHERS, DEPENDING
UPON THEIR INHERENT TOXICITY & CONCENTRATION. OF SPECIAL CONCERN
ARE CHROMIUM, NICKEL & PERHAPS MANGANESE.
================== Physical/Chemical Properties ==================
Spec Gravity:8-8.9
Appearance and Odor:ODORLESS SOLID W/METALLIC LUSTRE. AVAILABLE PLATES,
DISCS, HEADS & SLABS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:METAL FUMES & CERTAIN NOXIOUS GASES
SUCH AS CO. ACID PICKLING MAY RESULT IN THE FORMATION OF HEXAVALENT
CHROMIUM.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AQUASTAR COULOMAT A, AX1697A
CAGE:DO242
CAGE:63612
CAGE:DO242
============= Composition/Information on Ingredients =============
Ingred Name:METHANOL; (METHYL ALCOHOL)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 40-50%
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CHLOROFORM(SARA III)
CAS:67-66-3
RTECS #:FS9100000
Fraction by Wt: 30-40%
OSHA PEL:(C) 50 PPM
ACGIH TLV:10 PPM; A2; 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:IMIDAZOLE
CAS:288-32-4
RTECS #:NI3325000
Fraction by Wt: 10-20%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SULFUR DIOXIDE (SARA III)
CAS:7446-09-5
RTECS #:WS4550000
Fraction by Wt: 1-10%
OSHA PEL:5 PPM/5 STEL
ACGIH TLV:2 PPM/5 STEL; 9293
Ingred Name:SUPP DATA: DATA. EM SCIENCE RECOM SPILL-X ABSORB AGENTS FOR
VARIOUS TYPES OF SPILLS. ADDNL INFO ON SPILL-X PRODS (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: CAN BE PROVIDED THRU EM SCIENCE TECHNICAL SERVICE
DEPT (609) 354-9200. THE FOLLOWING EM SCIENCE SPILL-X (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: ABSORBENT IS RECOMMENDED FOR THIS PRODUCT: SOLVENT
SPILL TREATMENT KIT.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:LIQUID AND VAPOR ARE HIGHLY IRRITATING
TO SKIN, EYES, MUCOUS MEMBRANES. INHALATION MAY CAUSE EDEMA OF
LUNGS OR GLOTTIS AND CAN PRODUCE RESPIRATORY PARALYSIS, KIDNEY AND
LIVER DAMAGE. INGESTION MAY CAU SE BLINDNESS, NAUSEA, KIDNEY AND
LIVER DAMAGE.
Explanation of Carcinogenicity:CHLOROFORM:GROUP 2B (IARC)7,152,87,
ANTICIPATED TO BE A CARCINOGEN (NTP)6TH ANNUAL REPORT '91.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:LIVER, KIDNEY AND RESPIRATORY
CONDITIONS.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ASSISTANCE FOR ALL CASES OF OVEREXPOSURE. SKIN:
WASH THOROUGHLY WITH SOAP AND WATER. EYES: FLUSH THOROUGHLY WITH
WATER FOR AT LEAST 15 MINUTES. INHALATION: REMOVE TO FRESH AIR;
GIVE ARTIFI CIAL RESPIRATION IF NOT BREATHING. INGESTION: IF
CONSCIOUS, DRINK WATER AND INDUCE VOMITING IMMEDIATELY AS DIRECTED
BY MEDICAL PERSONNEL. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:54F,12.2C
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCES HIGHLY
TOXIC FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:EVAC AREA OF ALL UNNEC PERS. WEAR SUITABLE
PROT EQUIP LISTED UNDER EXPOS/PERS PROT. ELIM ALL IGNIT SOURCES
UNTIL AREA IS DETERM TO BE FREE FROM EXPLO/FIRE HAZ. CONTAIN RELS &
ELIM ITS SOURCE, IF THIS CAN BE DONE W/OUT RISK. TAKE UP AND
(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. STORE IN A
COOL, DRY AREA AWAY FROM IGNITION SOURCES.
Other Precautions:DO NOT BRTH VAP. FLAMM LIQ & VAP. CONTAINS MATL WHICH
MAY CAUSE CANCER BASED ON ANIMAL DATA. VAP HAZ. MAY BE FATAL/CAUSE
BLINDNESS IF SWALLOWED. CANNOT BE MADE NON-POIS. INHAL/INGEST MAY
CAUSE KIDNEY & LIVER DMG. IRRIT TO SKIN, EYES(SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF WORKPLACE EXPOS LIMIT(S) OF PROD/COMPONENT IS
EXCEEDED (SEE TLV/PEL), A NIOSH/MSHA APPRVD AIR SUPP RESP IS
ADVISED IN ABSENCE OF PROPER ENVIRON CNTRL. OSHA REGS ALSO PERMIT
OTHER NIOSH/MSHA APPRVD RESPS (NEG PRESS TYPE) UNDER (SUPDAT)
Ventilation:MATERIAL MUST BE HANDLED OR TRANSFERRED IN AN APPROVED FUME
HOOD OR WITH EQUIVALENT VENTILATION.
Other Protective Equipment:ENGINEERING &/OR ADMIN CNTRLS SHOULD BE
IMPLEMENTED TO REDUCE EXPOSURE. EYE WASH & SAFETY EQUIP SHOULD BE
READILY AVAIL.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. DO NOT TAKE
INTERNALLY.
Supplemental Safety and Health
OTHER PREC: & MUC MEMBS. BRTHG OF VAP MAY PRDCE HARMFUL EFTS ON
PREGNANCIES. RESP PROT: SPECIFIED CNDTNS (SEE YOUR SAFETY EQUIP
SUPP). SPILL PROC: CONTAINERIZE FOR PROPER DISP AS DESCRIBED UNDER
DISP. COMPLY W/FED, ST,& LOC REGS ON REPORTING RELS. REFER TO
REGULATORY INFO FOR REPORTABLE QTY & OTHER REGULATORY (ING 5)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:144F,62C
Vapor Pres:718 @ 55C
Solubility in Water:SLIGHT
Appearance and Odor:COLORLESS TO SLIGHTLY YELLOW LIQUID.
Percent Volatiles by Volume:99
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, ACIDS, OXIDIZERS.
Stability Condition to Avoid:HEAT, CONTACT WITH IGNITION SOURCES.
Hazardous Decomposition Products:OXIDES OF NITROGEN, OXIDES OF SULFUR,
IODINE, CHLORINE COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:SPECIFIED TECHNOLOGY - INCINERATION OR FUELS
BLENDING TO LESS THAN TCLP STANDARD. CONTACT LOCAL PERMITTED WASTE
DISPOSAL SITE (TSD) TO ASSURE COMPLIANCE W/ALL CURRENT LOCAL, STATE
& FEDERAL REGULATION S.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ALBUMIN FROM EGGS, A388-500
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:EGG WHITE POWDER; (ALBUMIN EGG) EINECS/ELINCS: UNLISTED.
CAS:9006-50-2
RTECS #:JX2550000
Code:F
= Wt:100.
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL,RAT): 101 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: DUST MAY CAUSE MECHANICAL
IRRITATION. SKIN: MAY CAUSE SKIN IRRITATION. LOW HAZARD FOR USUAL
INDUSTRIAL HANDLING. INGESTION: INGESTION OF LARGE AMOUNTS MAY
CAUSE GASTROINTESTINAL IRRITATION . EXPECTED TO BE A LOW INGESTION
HAZARD. INHALATION: MAY CAUSE RESPIRATORY TRACT IRRITATION. LOW
HAZARD FOR USUAL INDUSTRIAL HANDLING. CHRONIC: NO INFORMATION
FOUND. TARGET ORGANS: NONE.
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINUTES,
OCCASIONALLY LIFTING UPPER & LOWER LIDS. GET MEDICAL AID. SKIN:
FLUSH W/PLENTY OF SOAP & H*2O FOR AT LEAST 15 MIN WHILE REMOVING
CONTAMD CLOTHING & SHOES. GET MED AID IF IRRIT DEVELOPS/PERSISTS.
INGEST: IF VICITIM IS CONSCIOUS & ALERT, GIVE 2-4 CUPFULS OF
MILK/WATER. NEVER GIVE ANYTHING BY MOUTH TO UNCON PERSON. GET MED
AID. INHAL: REMOVE FROM EXPOSURE TO FRESH AIR IMMED. IF NOT
BREATHING, GIVE ARTF RESP. IF BREATHING IS DIFFICULT, GIVE OXYGEN.
GET MED AID IF COUGH/OTHER SYMPTOMS APPEAR. NOTES TO MD: TREAT
SYMPTOMATICALLY & SUPPORTIVELY. A NTIDOTE: NONE REPORTED.
===================== Fire Fighting Measures =====================
Lower Limits:NOT AVAIL
Upper Limits:NOT AVAIL
Extinguishing Media:IN CASE OF FIRE, USE WATER, DRY CHEMICAL, CHEMICAL
FOAM, OR ALCOHOL-RESISTANT FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . THIS MATERIAL IN SUFFICIENT QUANTITY AND REDUCED
PARTICLE SIZE IS CAPABLE OF CREATING A DUST EXPLOSION.
Unusual Fire/Explosion Hazard:NFPA RATING: NOT PUBLISHED.
================== Accidental Release Measures ==================
Spill Release Procedures:GENERAL INFORMATION: USE PROPER PERSONAL
PROTECTIVE EQUIPMENT AS INDICATED IN SECTION 8. SPILLS/LEAKS: SWEEP
UP, THEN PLACE INTO A SUITABLE CONTAINER FOR DISPOSAL. AVOID
GENERATING DUSTY CONDITIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLING: USE WITH ADEQUATE
VENTILATION. AVOID CONTACT WITH SKIN AND EYES. AVOID INGESTION AND
INHALATION. STORAGE: KEEP FROM CONTACT WITH OXIDIZING MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH OR EUROPEAN STANDARD EN 149
APPROVED FULL-FACEPIECE AIRLINE RESPIRATOR IN THE POSITIVE PRESSURE
MODE WITH EMERGENCY ESCAPE PROVISIONS.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
AIRBORNE CONCENTRATIONS BELOW THE PERMISSIBLE EXPOSURE LIMITS.
Other Protective Equipment:WEAR APPROPRIATE PROTECTIVE CLOTHING TO
MINIMIZE CONTACT WITH SKIN.
Supplemental Safety and Health
EMERGENCY OVERVIEW: YELLOW. CAUTION! THIS IS EXPECTED TO BE A LOW
HAZARD FOR USUAL INDUSTRIAL HANDLING. MAY CAUSE IRRITATION. TARGET
ORGANS: NONE. ACC# 00497.
================== Physical/Chemical Properties ==================
Boiling Pt:=61.C, 141.8F
Melt/Freeze Pt:=-.4C, 31.F
Decomp Temp:=60.C, 140.F
Vapor Pres:NEGLIGIBLE
Vapor Density:NKP
Spec Gravity:1.0
pH:7.6
Solubility in Water:SOLUBLE
Appearance and Odor:YELLOW SOLID; NO REPORTED ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:INCOMPATIBLE MATERIALS.
Hazardous Decomposition Products:CARBON MONOXIDE, OXIDES OF NITROGEN,
CARBON DIOXIDE.
Conditions to Avoid Polymerization:HAS NOT BEEN REPORTED.
=================== Toxicological Information===================
Toxicological Information:RTECS#: CAS # 9006-50-2: JX2550000 LD50/LC50:
CAS # 9006-50-2: ORAL, RAT: LD50 = 101 MG/KG. EPIDEMIOLOGY,
TERATOGENICITY, REPRODUCTIVE EFFECTS, NEUROTOXICITY, MUTAGENICITY:
NO DATA AVAILABLE. OTHER ST UDIES: NO DATA AVAILABLE. .
===================== Ecological Information =====================
Ecological:ECOTOXICITY: NOT AVAILABLE.ENVIRONMENTAL FATE: NOT
AVAILABLE . PHYSICIAN/CHEMICAL: NOT AVAILABLE. OTHER: NOT
AVAILABLE. CLEAN AIR ACT: THIS MATEIRAL DOES NOT CONTAIN ANY
HAZARDOUS AIR POLLUTANTS. TH IS MATERIAL DOES NOT CONTAIN ANY CLASS
1 OZONE DEPLETORS. THIS MATERIAL DOES NOT CONTAIN ANY CLASS 2 OZONE
DEPLETORS. CLEAN WATER ACT: NONE OF CHEMICALS IN THIS PRODUCT ARE
LISTED AS HAZ SUBSTANES UND ER CWA. NONE OF CHEMICALS IN THIS
PRODUCT ARE LISTED AS PRIORITY POLLUTANTS UNDER CWA. NONE OF
CHEMICALS IN THIS PRODUCT ARE LISTED AS TOXIC POLLUTANTS UNDER CWA.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE, AND LOCAL REGULATIONS. RCRA D-SERIES MAXIMUM CONCENTRATION
OF CONTAMINANTS, RCRA D-SERIES CHRONIC TOXICITY REFERENCE LEVELS,
RCRA F-SERIES, RCRA P-SERIES, RCRA U-SERIES: NONE LISTESD.
===================== Regulatory Information =====================
SARA Title III Information:SECTION 302 (RQ): NONE OF THE CHEMICALS IN
THIS MATERIAL HAVE AN RQ. SECTION 302 (TPQ): NONE OF THE CHEMICALS
IN THIS PRODUCT HAVE A TPQ. SECTION 313: NO CHEMICALS ARE
REPORTABLE UNDER SECTION 313.
Federal Regulatory Information:TSCA CAS# 9006-50-2 IS LISTED ON TSCA
INVENTORY. HEALTH & SAFETY REPORTING LIST: NONE OF THE CHEMICALS
ARE ON THE HEALTH & SAFETY REPORTING LIST. EUPORPEAN/INTERNAIONAL
REGULATIONS EUROPEAN LABELING I N ACCORDANCE WITH EC DIRECTIVES
HAZARDS SYMBOLS: NOT AVAILABLE. WGK (WATER DANGER/PROTECTION): CAS
# 9006-50-2: NO INFORMAITON AVAILABLE. CANADA: NONE OF THE
CHEMICALS IN THIS PRODUCT ARE LISTED ON TH E DSL/NDSL LIST. THIS
PRODUCT HAS A WHMIS CLASSIFICATION OF NOT CONTROLLED. CAS#
9006-50-2 IS NOT LI STED ON CANDA'S INGREDIENT DISCLOSURE LIST.
OSHA: NONE OF HTE CHEMICALS IN THIS PRODUCT ARE CONSIDERED HIGHLY
HAZARDOUS BY OSHA.
State Regulatory Information:CAS# 9006-50-2 IS NOT PRESENT ON STATE
LISTS FROM CA, PA, MN, MA, FL, OR NJ. CALISFORNIA NO SIGNIFICANT
RISK LEVEL: NONE OF THE CHEMICALS IN THIS PRODUCT ARE LISTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RTV ADHESIVE SEALANT
CAGE:0DF77
CAGE:0DF77
============= Composition/Information on Ingredients =============
Ingred Name:METHYLTRIACETOXYSILANE
CAS:4253-34-3
RTECS #:VV4500000
Other REC Limits:NONE RECOMMENDED
Ingred Name:ACETIC ACID (CERCLA)
CAS:64-19-7
RTECS #:AF1225000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 PPM
ACGIH TLV:10 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITATION. SKIN: IRRITATION.
INHAL: NO TOXIC EFFECTS. INGEST: NOT EXPECTED IN INDUSTRIAL USE.
Effects of Overexposure:ACETIC ACID IS A SEVERE SKIN/EYE/MUCOUS
MEMBRANE IRRITANT. SKIN SENSITIZATION RARE. CHRONIC: MAY CAUSE
BRONCHITIS AND PHARYNEAL EDEMA. MAY CAUSE BURNS UPON
PROLONGED/REPEATED CONTACT.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/RUNNING WATER 15 MINUTES, LIFT LIDS TO ENSURE
RINSING, GET MED AID. SKIN: REMOVE AS MUCH AS POSSIBLE USING
MECHANICAL/WATERLESS METHODS BEFORE WASHING W/WATER. GET MED AID
FOR BURNS OR IR RITATION. INGEST: NA INHAL: REMOVE TO FRESH AIR.
PROVIDE OXYGEN IF BREATHING DIF. GIVE CPR IF NOT BREATHING, GET MED
AID.
===================== Fire Fighting Measures =====================
Flash Point:NA
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:WATER SPRAY, DRY CHEMICALS, CARBON DIOXIDE.
Fire Fighting Procedures:EVAC NONESSENTIAL PERSONNEL. WEAR FULLFACE
SCBA, IMPERVIOUS PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:WILL BURN W/LAZY SMOULDERING TYPE FLAME.
VAPORS WILL ACCUMULATE IN CONTAINER HEADSPACE ON FORMATION OF
HYDROLYSIS BI-PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:USE POSITIVE PRESSURE SCBA IF UNKNOWN
CONCENTRATION OF VAPOR OR AEROSOL FOR LARGE SPILLS. SM SPILLS:
ADEQUATE VENT. WEAR NIOSH APPROVED RESPIRATOR W/DUST/MIST FUME
FILTER. WEAR PROTECTIVE CLOTHES TO P REVENT SKIN/EYE CONTACT. *
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY WELL VENTED AREA.
KEP CONTAINER CLOSED AND AIR TIGHT TO PREVENT CURING. OPEN
CONTAINER W/CARE. COMBUSTIBLE VAPORS MAY BE PRESENT.
Other Precautions:*ABSORB SPILL W/SAND OR FULLERS EARTH. SWEEP UP AND
PLACE IN APPROPRIATE CHEMICAL WASTE CONTAINER. FLUSH AREA W/WATER.
OBSERVE ALL LOCAL FEDERAL AND STATE REGULATIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ADEQUATE VENT NOT AVAILABLE USE APPROPRIATE
AIR PURIFYING OR SUPLIED AIR RESPIRATORS IN ACCORDANCE W/NIOSH
GUIDELINES.
Ventilation:ADEQUATE VENTILATION TO MAINTAIN BELOW EXOSURE LIMITS.
Work Hygienic Practices:OBSERVE GENERAL WORK HYGIENIC PRACTICES.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NA
Melt/Freeze Pt:M.P/F.P Text:NA
Decomp Temp:Decomp Text:NA
Vapor Pres:NA
Vapor Density:4 AIR = 1
Spec Gravity:1.08 WATER = 1
pH:NA
Viscosity:NA
Evaporation Rate & Reference:NA
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TRANSPARENT, CLEAR PASTE, ACETIC ACID ODOR.
Percent Volatiles by Volume:400
Corrosion Rate:NA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NA
Stability Condition to Avoid:NA
Hazardous Decomposition Products:SIO2, CO, CO2, FORMALDEHYDE, VARIOUS
HYDROCARBON FRAGMENTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE W/FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LIFTKLEEN
CAGE:FO798
CAGE:FO798
CAGE:4S446
============= Composition/Information on Ingredients =============
Ingred Name:METASILICATE
Fraction by Wt: 3%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS & SYMPTOMS OF OVEREXPOSURE
SECTION .
Explanation of Carcinogenicity:NOT APPLICABLE
Effects of Overexposure:NONE (MFR)
Medical Cond Aggravated by Exposure:N/K
======================= First Aid Measures =======================
First Aid:EYE:IMME FLUSH W/LGE AMTS OF WTR FOR AT LEAST 15 MIN.
SKIN:WASH W/SOAP & WTR. INHALATION:REMOVE FROM EXPOSURE. SUPPORT
BREATHING(GIVE O*2/ARTIFICIAL RESPIRATION). INGESTION:CALL MD I
MMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Lower Limits:N/K
Upper Limits:N/K
Extinguishing Media:NO SPECIAL REQUIREMENTS.
Fire Fighting Procedures:NO SPECIAL REQUIREMENTS.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:WASH DOWN W/WTR & DRAIN.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:N/K
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE(MFR). NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE (MFR)
Other Protective Equipment:N/K
Work Hygienic Practices:N/K
Supplemental Safety and Health
RTE ENTRY:N.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F/100C
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Spec Gravity:1.058
pH:12-13
Evaporation Rate & Reference:SIMILAR TO WATER
Solubility in Water:100%
Appearance and Odor:PINK-RED LIQUID, ODORLESS
Percent Volatiles by Volume:93.5
Corrosion Rate:
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
DO NOT MIX W/ACIDS.
Stability Condition to Avoid:N/K
Hazardous Decomposition Products:N/K
==================== Disposal Considerations ====================
Waste Disposal Methods:BIODEGRADEABLE MATERIAL (PH 12 TO 13). WET
VACUUM PICKUP/FLUSH W/WTR. DISPOSE OF IN ACCORDANCE W/LOCAL, STATE
& FEDERAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LEAD ACID BATTERY
CAGE:60038
CAGE:0FTM0
CAGE:20038
CAGE:60038
============= Composition/Information on Ingredients =============
Ingred Name:SULFURIC ACID (SARA III)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 10-30%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:LEAD (SARA III)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 60%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.05 MG/M3;1910.1025
ACGIH TLV:0.15 MG/M3;DUST 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ANTIMONY (SARA III)
CAS:7440-36-0
RTECS #:CC4025000
Fraction by Wt: 2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.5 MG/M3
ACGIH TLV:0.5 MG SB/M3; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ARSENIC (SARA III)
CAS:7440-38-2
RTECS #:CG0525000
Fraction by Wt: 0.2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.5 MG/M3 (AS)
ACGIH TLV:0.01,A1 MG/M3; 9394
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CALCIUM, METAL
CAS:7440-70-2
RTECS #:EV8040000
Fraction by Wt: 0.2%
Other REC Limits:NONE SPECIFIED
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
Fraction by Wt: 0.2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9192
Ingred Name:POLYPROPYLENE
CAS:9003-07-4
RTECS #:UD1842000
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
Ingred Name:POLYSTYRENE
CAS:9003-53-6
RTECS #:WL6475000
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
Ingred Name:STYRENE ACRYLONITRILE
CAS:9003-54-7
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
Ingred Name:ACRYLONITRILE BUTADIENE STYRENE
CAS:9003-56-9
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
Ingred Name:STYRENE BUTADIENE
CAS:9003-55-8
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
Ingred Name:POLYVINYLCHLORIDE
CAS:9002-86-2
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
Ingred Name:POLYCARBONATE
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
Ingred Name:HARD RUBBER
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: BURNS, SEVERE IRRITATION OF
SKIN, EYES, MOUTH, THROAT, ESOPHAGUS AND STOMACH; INFLAMMATION OF
BRONCHIAL MEMBRANES. CHRONIC: EROSION OF TEETH, INFLAMMATION OF
NOSE, THROAT AND BRONCHIAL TUBES.
Explanation of Carcinogenicity:LEAD IS LISTED BY IARC AND NTP. ARSENIC
IS LISTED BY IARC, NTP AND OSHA.
Effects of Overexposure:COUGH, INCREASED RESPIRATORY RATE, STINGING,
BURNING SENSATION ON SKIN, EYE IRRITATION, DISCOLORATION OF TEETH.
Medical Cond Aggravated by Exposure:EXPOSURE TO MISTS MAY CAUSE LUNG
DAMAGE AND AGGRAVATE PULMONARY CONDITIONS. CONTACT WITH SKIN MAY
AGGRAVATE SKIN DISEASES SUCH AS ECZEMA AND CONTACT DERMATITIS.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH WITH PLENTY OF WATER. SEE DOCTOR
IMMEDIATELY. REMOVE CONTAMINATED CLOTHING AND SHOES. INHALATION:
REMOVE TO FRESH AIR. GIVE OXYGEN/CPR IF NEEDED. SEE DOCTOR.
INGESTION: DO NOT INDUCE VOMITING. GIVE MILK OR WATER, FOLLOWED BY
2 OUNCES OF MILK OF MAGNESIA (NO CARBONATES). SEE DOCTOR
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:4.1(HYDROGN)
Upper Limits:74(HYDROGEN)
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL, HALOGEN.
Fire Fighting Procedures:IF BATTERIES ARE ON CHARGE, SHUT OFF POWER.
USE POSITIVE PRESSURE SCBA. WATER APPLIED TO ACID GENERATES HEAT
AND CAUSES SPATTER. WEAR ACID-RESISTANT CLOTHING.
Unusual Fire/Explosion Hazard:FLAMMABLE AND EXPLOSIVE HYDROGEN GAS IS
PRODUCED DURING CHARGING AND OPERATION. REMOVE ALL IGNITION
SOURCES. VENTILATE AREA.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR APPROPIATE PROTECTIVE EQUIPMENT. DILUTE
CAUTIOUSLY WITH WATER. COVER WITH SODA ASH OR QUICKLIME. SCOOP UP
AND PLACE IN APPROPIATE DISPOSAL CONTAINER. FLUSH AREA WITH LARGE
AMOUNTS OF WATER.
Neutralizing Agent:SODA ASH (SODIUM CARBONATE), BAKING SODA OR
QUICKLIME (CALCIUM OXIDE).
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE. STORE AWAY
FROM FLAMES, IGNITION SOURCES, COMBUSTIBLE AND ORGANIC MATERIALS.
AVOID PROLONGED OVERCHARGING.
Other Precautions:DO NOT CARRY BATTERY BY TERMINALS. DO NOT DROP
BATTERY, PUNCTURE OR ATTEMPT TO OPEN BATTERY CASE. KEEP TERMINALS
COVERED IN PLASTIC CASE. AVOID SHORTING BATTERIES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. NIOSH/MSHA-APPROVED
CARTRIDGE RESPIRATOR FOR ACIDS OR FULL FACE MASK AS APPROPIATE FOR
EXPOSURE OF CONCERN WHEN TLV IS EXCEEDED.
Ventilation:GENERAL (MECHANICAL) VENTILATION. LOCAL EXHAUST IN CONFINED
AREAS. USE ACID RESISTANT COMPONENTS.
Other Protective Equipment:RUBBER APRON AND BOOTS IF CONTACT IS
EXPECTED. EYE WASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
THIS MSDS WAS PREPARED FOR SULFURIC ACID EXPOSURE. HAZARDOUS EXPOSURE
TO LEAD COMPOUNDS CAN OCCUR ONLY WHEN PRODUCT IS HEATED, OXIDIZED
OR OTHERWISE PROCESSED OR DAMAGED TO CREATE DUST, VAPOR OR FUME.
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:=95.C, 203.F
Vapor Pres:10
Vapor Density:>1
Spec Gravity:1.23-1.35
pH:ACIDIC
Evaporation Rate & Reference:<1 (BUTYL ACETATE = 1)
Solubility in Water:COMPLETE
Appearance and Odor:ACID IN BATTERY IS CLEAR LIQUID WITH SHARP,
PENETRATING, PUNGENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
COMBUSTIBLES, ORGANIC MATERIAL, STRONG REDUCING AGENTS, METALS, SULFUR
TRIOXIDE GAS, STRONG OXIDIZERS, WATER.
Stability Condition to Avoid:AVOID SHORTING, USE ONLY APPROVED CHARGING
METHODS. AVOID OVERCHARGING AND SOURCES OF IGNITION.
Hazardous Decomposition Products:SULFURIC ACID FUMES, SULFUR DIOXIDE,
SULFUR TRIOXIDE, CARBON MONOXIDE, HYDROGEN GAS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGUALTIONS. SPEND BATTERIES: SEND TO SECONDARY LEAD
SMELTER FOR RECYCLING.
| 1 | gloves_mandatory |
=======================================================
Product ID: PELMOR PLV 2040 AEROSPRAY
Cage: EO919
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 24802
Cage: EO919
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: SEE INGREDIENT 2
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: ACUTE:EYES: IRRITATION & BURNING SENSATION. SKIN:
DRYING-IRRITATION. INHAL: IRRITATES EYES, NOSE & RESP TRACT. HEADACHE,
DIZZINESS, & IN EXTREME CASES, UNCONSCIOUSNESS. INGEST: IRRITATION -
INGESTION OF SEVERAL OUNCES CAN CAUSE NARCOSIS & ACIDOSIS. CHRONIC:
EYES: IRRITATION. SKIN: MAY CAUSE DERMATITIS.(EFTS OF OVEREXP)
Explanation Of Carcinogenicity: USERS OF THE "L" VERSION OF TO CONSULT "LR"
VERSION
Signs And Symptions Of Overexposure: HLTH HAZ: CHLOROCARBON MATLS HAVE PRDCD
SENSIT OF THE MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS & COULD HAVE A
SIMILAR EFT IN HUMANS. ADRENOMIMETICS (E.G., EPINEPHRINE)MAY BE
CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINING USES IN HUMANS
ACUTELY/CHRONICALLY EXPOS TO CHLOROCARBONS(FP N). ANIMAL STUDIES HAVE (SUPP
DATA)
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES: IMMEDIATELY WASH W/PLENTY OF WATER INCLG UNDER EYELIDS. IF
IRRIT PERSISTS, GET MED ATTN. SKIN: WASH W/SOAP & WATER. REMOVE CONTAMD
CLTHG IMMED. INGEST: IF VICTIM IS CONSCIOUS & MED HELP IS NOT R EADILY
AVAIL, GIVE HIM 3 GLASSES OF WATER/MILK TO DRINK & INDUCE VOMIT. GET MED
HELP AS SOON AS POSS, W/SPECIAL ATTN TO ACIDOSIS. INHAL: REMOVE VICTIM TO
FRESH AIR. IF REQD, RESTORE BRTHG (SUPP DATA)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: AVOID ALL PERSONAL CONTACT. USE ALL SAFETY EQUIPMENT.
CONTAIN SPILL. SOAK UP THE PRODUCT WITH ABSORBENT MATERIAL AND SHOVEL IT INTO
EMPTY DRUMS. HOLD FOR DISPOSAL.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: UNDER RCRA REGS, IT IS RESPONSIBILITY OF USER OF PROD
TO DETERMINE AT TIME OF DISP WHETHER PROD MEETS RCRA CRITERIA FOR HAZ WASTE.
PRODUCT USES/CONTAM MAY RENDER RSLTG MATL HAZ. PROD IF DISCARDED AS R
ECEIVED, IS HAZ WASTE & BEARS EPA HAZ WASTE #F003.
Handling And Storage Precautions: STORE IN A COOL DRY AREA-AWAY FROM HEAT,
SPARKS AND OPEN FLAMES & OXIDIZING AGENTS.
Other Precautions: NO SMOKING IN AREA OF USE. DO NOT USE IN THE GENERAL
VICINITY OF ARC WELDING, OPEN FLAMES OR HOT SURFACES. HEAT AND/OR UV
RADIATION MAY CAUSE THE FORMATION OF HCL &/PHOSGENE (FP N).
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point Text: 17.0F,-8.3C
Lower Limits: 1.1%
Upper Limits: 7.5%
Extinguishing Media: CO*2, DRY CHEMICAL, CARBON DIOXIDE, ALCOHOL FOAM, WATER
SPRAY.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA &
FULL PROTECTIVE EQUIPMENT(FP N).
Unusual Fire/Explosion Hazard: VAPORS ARE HVR/AIR & CAN FLOW ALONG SURFACES
TO A DISTANT SOURCE OF IGNITION AND FLASH BACK. THERMAL DECOMP PRODS MAY INCL
HCL & PHOSGENE(FP N).
=======================================================
Control Measures
=======================================================
Respiratory Protection: FOR EMERGENCY/NON ROUTINE USE ABOVE THE TLV, USE
APPROVED NIOSH/MSHA FULL FACEPIECE ORGANIC VAPOR CANISTER VAPOR MASK. FOR
UNKNOWN CONCENTRATIONS/THOSE ABOVE 3000 PPM, USE NIOSH/MSHA APPRVD SELF-CNTND
/AIR SUPPLIED RESPIRATOR.
Ventilation: PROVIDE GENL & LOC EXHST FUME VENT TO MEET TLV REQS. ALL
ELECTRICAL SERVICES MUST BE OF EXPLOSION PROOF CONSTRUCTION.
Other Protective Equipment: APRON AND OTHER PROTECTIVE CLOTHING. EYE WASH
STATION. DO NOT WEAR CONTACT LENSES WHEN WORKING W/THIS PRODUCT.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: USERS OF THE "L" VERSION OF TO CONSULT "LR"
VERSION FOR ADDITIONAL INFO(FP N). FIRST AID PROC: BY ARTF RESP. KEEP VICTIM
WARM & AT REST. GET IMMEDIATE MED ATTN. EFTS OF OVEREXP: CLEARLY
DEMONSTRA TED DOSE-RELATED ADVERSE EFFECTS ON THECNS, HEMATOPOIETIC TISSUE,
BLOOD, KIDNEYS & THE LIVER ASSOC W/ADMIN
=======================================================
Physical/Chemical Properties
=======================================================
HCC: V3
Vapor Density: HVR/AIR
Solubility in Water: 100% IN WATER
Appearance and Odor: BLACK LIQUID.
Percent Volatiles by Volume: 82(WT)
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HIGH TEMPERATURE.
Materials To Avoid: NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products: TOX & CORR DECOMP & OXIDATION PRODS CAN FORM
WHEN PROD IS HEATED TO HIGH TEMPS IN FIRE SITUATION. HCL, PHOSGENE(FP N).
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: PELMOR PLV 2040 AEROSPRAY
Cage: EO919
Assigned IND: Y
Company Name: PELMOR LABORATORIES INC
Street: 401 LAFAYETTE ST
Zipcode: 18940-2151
Label Required IND: Y
Date Of Label Review: 10/24/1994
Status Code: C
Label Date: 10/24/1994
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE. ACUTE: INHAL OF MIST OR VAPORS MAY
CONTRIBUTE TO OCCURRENCE OF IRREG HEARTBEAT(FP N). EYES: IRRITATION &
BURNING SENSATION. SKIN: DRYING-IRRITATION. INHAL: IRRITATES EYES, NOSE &
RESP TRACT . HEADACHE, DIZZINESS, & IN EXTREME CASES, UNCONSCIOUSNESS.
INGEST: IRRIT - INGEST OF SEVERAL OUNCES CAN CAUSE NARCOSIS & ACIDOSIS.
CHRONIC: CANCER HAZARD. CONTAINS MATL WHICH IS LISTED AS AN ANIMAL L UNG
CARCINOGEN(FP N). ANIMAL STUDIES HAVE CLEARLY SHOWN DOSE RELATED ADVERSE
EFFECTS TO CNS, BLOOD FORMING TISSUE, BLOOD, LIVER & KIDNEYS ASSOCIATED
WITH ADMINISTRATION OF MATERIAL IN THIS PRODUCT(FP N). EYES:IRRITATION.
SKIN: MAY CAUSE DERMATITIS.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CADMIUM 10,000 UG/ML (1% W/V)
CAGE:0EK28
CAGE:0EK28
============= Composition/Information on Ingredients =============
Ingred Name:CADMIUM (II) NITRATE, TETRAHYDRATE (1:2:4)ACGIH SUSPECTED
CARCINOGEN
CAS:10022-68-1
RTECS #:EV1850000
Fraction by Wt: 2.11%
OSHA PEL:0.05 MG/CUM (CD)
ACGIH TLV:0.01 MG(CD)/CUM
Ingred Name:NITRIC ACID, HYDROGEN NITRATE *96-4*
CAS:7697-37-2
RTECS #:QU5775000
Fraction by Wt: 0-5%
OSHA PEL:5 MG/CUM
ACGIH TLV:5.2 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT):300 MG/KG CADMIUM NITRATE
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: MAY CAUSE BURNS. VAPORS MAY
AFFECT INHALATION & INGESTION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:BURNS, COUGHING, DIFFICULTY BREATHING, NAUSEA,
VOMITING, LOSS OF CONSCIOUSNESS
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:INGESTION: DON'T INDUCE VOMITING. IF CONSCIOUS, GIVE WATER,
MILK/MILK OF MAGNESIA. EYES/SKIN: IMMEDIATELY FLUSH W/PLENTY OF
WATER FOR 15 MINS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR PROPER PROTECTIVE EQUIPMENT & SELF
CONTAINED BREATHING APPARATUS W/FULL FACEPIECE OPERATED IN POSITIVE
PRESSURE MODE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SCBA & FULL PROTECTIVE CLOTHING. STOP
LEAK SAFELY W/O RISK. USE WATER SPRAY TO REDUCE VAPORS. TAKE UP
W/SAND/OTHER NON-COMBUSTIBLE ABSORBENT MATERIAL & PLACE INTO
CONTAINER FOR LATER DISPOSAL. FL USH AREA W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN CORROSION-PROOF AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:REQUIRED
Ventilation:LOCAL EXHAUST, VENT HOOD
Other Protective Equipment:LAB COAT
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Spec Gravity:1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS SOLUTION W/NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ORGANIC MATERIALS, STRONG REDUCING AGENTS
Hazardous Decomposition Products:OXIDES OF NITROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS. EPA HAZARDOUS WASTE # D002 (CORROSIVE WASTE).
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MAGNESIUM CHLORIDE FLAKES
Preparer's Name:DGSC-SSH (PRIVOTT)
CAGE:97984
CAGE:97984
============= Composition/Information on Ingredients =============
Ingred Name:MAGNESIUM CHLORIDE FLAKES (AS HEXAHYDRATE)
CAS:7791-18-6
RTECS #:OM2975000
Fraction by Wt: >99% %
Other REC Limits:NONE SPECIFIED
ACGIH TLV:10 MG/M3 RESP DUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:PRODUCT CONTAINS NO MATERIALS CURRENTLY
CLASSIFIED AS CARCINOGENIC BY NTP, OSHA OR IARC.
Effects of Overexposure:MFR STATES "NONE"; EYES: IRRITANT; INHAL:
IRRITANT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: WASH OUT THOROUGHLY WITH WATER. INHALATION: REMOVE TO
FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE
Fire Fighting Procedures:NO PARTICULAR MEASURES REQUIRED.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:NO PARTICULAR MEASURES REQUIRED. SWEEP UP
MATERIAL & PLACE IN APPROVED CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:MATERIAL IS HIGHLY HYGROSCOPIC &
DILIGUESCES ABOVE 30% RELATIVE HUMIDITY. MUST BE STORED UNDER DRY
CONDITIONS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED. HOWEVER, DUST MASK/
RESPIRATORY MAY BE NEEDED UNDER CERTAIN CIRCUMSTANCES.
Ventilation:NORMAL ROOM VENTILATION.
Other Protective Equipment:NOT NECESSARY
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
AMCO NO LONGER IN BUSINESS AND UNABLE TO SUPPLY MSDS FOR PRODUCT. MSDS
CREATED BY DGSC-SSH FOR PURE CHEMICAL BASED ON PRODUCT/MSDS
SUPPLIED BY OCTAGON FOR SAME NSN.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:DECOMPOSES
Melt/Freeze Pt:M.P/F.P Text:242.6F/117C
Vapor Pres:0.7 @ 68F
Vapor Density:0.0
Spec Gravity:1.6 @ 68F
Evaporation Rate & Reference:DEHYDRATION
Solubility in Water:440 GM/L @ 68F
Appearance and Odor:WHITE TO GREY SCALY FLAKES, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:HYDROCHLORIC ACID EVENTUALLY CHLORINE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL STATE, LOCAL
AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-C-85570 TYPE II,CLEANING COMPD AIRCRAFT
CAGE:56921
CAGE:56921
============= Composition/Information on Ingredients =============
Ingred Name:DIPROPYLENE GLYCOL METHYL ETHER
CAS:34590-94-8
RTECS #:JM1575000
Fraction by Wt: 10%
OSHA PEL:S,100PPM/150STEL
ACGIH TLV:S,100PPM/150STEL9192
Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: 90%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Effects of Overexposure:EYE:MILD IRRITATION; SKIN:PROLONGED ACT MAY
CAUSE DEFATTING; INH:EXCESSIVE INHALATION OR MIST OR VAPORS MAY BE
MILDLY IRRITATING; ING:MAY CAUSE GASTROINTESTINAL
IRRITATION,NAUSEA,VOMITING,& DIARRHEA.
======================= First Aid Measures =======================
First Aid:SKIN:WASH W.SOAP & H*2O. EYES:FLUSH W. H*2O. INGESTED:DON'T
INDUCE VOMITING. INHALED:REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF
NEED. KEEP WARM & QUIET. REMOVE CONTAMINATED CLOTHING. NEVER GIVE
ANYTHING BY MOUTH TO UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Extinguishing Media:NONE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH WITH LARGE QUANTITIES OF WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE UNDER NORMAL USE.
Ventilation:MECHANICAL/LOCAL EXHAUST FOR EXCESSIVE VAPORS.
Other Protective Equipment:NONE
Work Hygienic Practices:AVOID EXCESSIVE CONTACT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F/100C
Spec Gravity:1.0096
Solubility in Water:COMPLETE (100%)
Appearance and Odor:CLEAR LIQUID-SLIGHT ORGANIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING OR REDUCING AGENTS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:MAY FORM CARBON DIOXIDE & CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: ENVIROSOLVE 652
Cage: 05867
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 05867
Box: 2277
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: SEE INGREDIENT 2.
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:INHAL:EXCESSIVE REPEATED CONTACT OF CONCENTRATED
MATERIAL MAY CAUSE IRRITATION. INGEST:HARMFUL IF ASPIRATED INTO LUNGS.
CHRONIC:NONE CURRENTLY KNOWN. ING 2:LIKE MANY HYDROCARBONS LIQUIDS, THIS S
OLVENT WILL DRY & DEFAT SKIN ON PROLONGED CONTACT & MAY RESULT IN
SKIN IRRITATION & DERMATITIS.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE CURRENTLY KNOWN.
First Aid: INHAL:REMOVE TO FRESH AIR. EYE:FLUSH THOROUGHLY W/WATER FOR AT LEAST
15 MINUTES W/IN ONE MINUTE OF CONTACT. SKIN:WASH AREAS OF CONTACT W/GENEROUS
AMOUNTS OF WATER. REMOVE CONTAMINATED CLOTHING. LAUNDE R BEFORE REUSE.
INGEST:DO NOT INDUCE VOMITING. GIVE PLENTY OF WATER. SEEK MEDICAL ATTENTION
IN ANY NECESSARY INSTANCES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: IF OUTDOORS, ADD SAND, EARTH/OTHER SUITABLE ABSORB TO
SPILL AREA. KEEP PROD OUT OF SEWERS & WATER COURSES BY DIKING/
IMPOUNDING. INSIDE SPILLAGE, SHUT OFF/ELIM ALL IGNIT SOURCES & REMOVE W/
ABSORB MAT L. SWEEP UP ABSORB MATL & FOLLOW WASTE DISP METHS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISP I/A/W 42 USG325/ET SEQ RCRA 1976. DISP I/A/W ALL
LOCAL, STATE & FEDERAL REGS. DISPOSAL RECOMMENDATIONS APPLY TO ORIGINAL
MATERIAL & ITS CONTAINER & NOT ANY MATERIALS WHICH ARE A WASTE
BY-PRODUCT OF THE USER'S OPERATION.
Handling And Storage Precautions: KEEP BELOW 140F. STORAGE PRESSURE: NORMAL.
REASONABLE CARE & PRECS WHEN HANDLING THIS MATL ARE STRONGLY REC. DO NOT
STORE NEAR HEAT, SPKS/OPEN FLAMES.
Other Precautions: THIS CONTAINER MAY BE HAZARDOUS WHEN EMPTIED. EMPTIED
CONTAINERS MAY RETAIN PRODUCT RESIDUES (VAPORS OR LIQUID). OBSERVE ALL
LABELED HAZARD PRECAUTIONS.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: 148F,64C
Extinguishing Media: DRY CHEMICAL, WATER SPRAY, FOAM OR CARBON DIOXIDE
EXTINGUISHER.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). AVOID BREATHING SMOKE OR VAPORS.
Unusual Fire/Explosion Hazard: NONE KNOWN
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH/MSHA APPROVED RESPIRATOR WHEN OPERATING ABOVE THE
SUGGESTED TLV LIMITS.
Ventilation: CONTROL AIRBORNE CONCS BELOW EXPOS GUIDELINES. ALTHOUGH NO
OFFICIAL EXPOS LIMS HAVE BEEN ESTABLISHED, MFR (SUPP DATA)
Other Protective Equipment: NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: NOTE:USER OF "L" VERSION SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). VENT:SUGGESTS THAT, VAP CONCS FOR EMPLOYEE
EXPOS BE LTD TO BTWN 100-200 PPM, TWA. USE ONLY W/ADEQ VENT. LOCAL EXHAUST
VENT M AY BE NECESSARY FOR SOME OPERATIONS. EYE PROT:& ANSI Z87.1-1968.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: V4
B.P. Text: 347F,175C
Spec Gravity: 0.775
Solubility in Water: NEGLIGIBLE
Appearance and Odor: CLEAR GOLDEN LIQUID.
Percent Volatiles by Volume: 100
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: AVOID CONTACT W/OXIDIZING AGENTS.
Hazardous Decomposition Products: INCLUDES OXIDES OF CARBON.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: ENVIROSOLVE 652
Cage: 05867
Company Name: FINE ORGANICS CORP
Street: 420 KULLER RD
PO Box: 2277
Zipcode: 07015
Label Required IND: Y
Date Of Label Review: 11/17/1993
Status Code: C
Label Date: 11/17/1993
Origination Code: G
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE:INHAL:EXCESSIVE REPEATED CONTACT OF
CONCENTRATED MATERIAL MAY CAUSE IRRITATION. INGEST:HARMFUL IF ASPIRATED INTO
LUNGS. LIKE MANY HYDROCARBONS LIQUIDS, THIS SOLVENT WILL DRY & DEFAT
SKIN ON PROLONGED CONTACT & MAY RESULTIN SKIN IRRITATION &
DERMATITIS. CHRONIC:NONE LISTED BY MANUFACTURER.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RUST TOUGH, RTA9211 SUNFLOWER YELLOW
CAGE:DO642
CAGE:DO642
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC, HIGH FLASH
AROMATIC NAPHTHA
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 4%
Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 27%
OSHA PEL:2400 MG/CUM
ACGIH TLV:750 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL PROPYL KETONE
CAS:107-87-9
RTECS #:SA7875000
Fraction by Wt: 8%
Other REC Limits:200 PPM
OSHA PEL:700 MG/CUM
ACGIH TLV:705 MG/CUM
Ingred Name:VOL ORGANIC CMPD: 74 PERCENT BY WEIGHT
RTECS #:9999999VO
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 13%
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 7%
Other REC Limits:1000 PPM
OSHA PEL:1800 MG/CUM
ACGIH TLV:1000 PPM
Ingred Name:LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA, LACOLENE*93/4*
CAS:64742-89-8
Fraction by Wt: 5%
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 5%
Other REC Limits:375 MG/CUM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 4%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF EYES, SKIN & RESPIRATORY
SYSTEM. INHALATION: NERVOUS SYSTEM DEPRESSION; MAY BE FATAL.
PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE ADVERSE EFFECTS TO
LIVER, URINARY & REPRODUCTIVE SYSTEM S; PERMANENT BRAIN & NERVOUS
SYSTEM DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: HEADACHE, DIZZINESS, NAUSEA, LOSS
OF COORDINATION, UNCONSCIOUSNESS & DEATH. EYES/SKIN: REDNESS,
ITCHING & BURNING SENSATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. KEEP
WARM/QUIET. SKIN: WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH
W/PLENTY OF WATER FOR 15 MINS. INGESTION: NEVER GIVE ANYTHING BY
MOUTH IF UNCONSC IOUS. DON'T INDUCE VOMITING. GIVE SEVERAL GLASSES
OF WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:<0F
Lower Limits:0.7%
Upper Limits:6%
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT INCLUDING SCBA.
WATER SPRAY MAY BE INEFFECTIVE, BUT MAY BE USED TO COOL CLOSED
CONTAINERS. FOG NOZZLES ARE PREFERABLE.
Unusual Fire/Explosion Hazard:WATER MAY BE USED TO COOL CLOSED
CONTAINERS TO PREVENT PRESSURE BUILD-UP, POSSIBLE AUTOIGNITION OR
EXPLOSION WHEN EXPOSED TO EXTREME HEAT. FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. VENTILATE &
REMOVE W/INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:USE APPROVED BONDING/GROUNDING
PROCEDURES. CONTENTS UNDER PRESSURE. DON'T PUNCTURE, INCINERATE, OR
EXPOSE TO TEMPERATURES >120F. DON'T SMOKE.
Other Precautions:HEAT FROM SUNLIGHT/RADIATORS/STOVES/HOT WATER/OTHER
HEAT SOURCES COULD CAUSE CONTAINER TO BURST. DON'T TAKE INTERNALLY.
KEEP OUT OF REACH OF CHILDREN. KEEP AREA VENTILATED. AVOID
BREATHING VAPOR/SPRAY MIST. AVOID SKIN & EYE CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A PROPERLY FITTED ORGANIC VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA. WHEN SANDING/ABRADING THE DRIED
FILM, WEAR A DUST/MIST RESPIRATOR APPROVED BY NIOSH/MSHA FOR DUST.
(SEE SUPPL.)
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS AFTER USING.
Supplemental Safety and Health
THIS COATING MAY CONTAIN MATERIALS CLASSIFIED AS NUISANCE PARTICULATES
WHICH MAY BE PRESENT AT HAZARDOUS LEVELS ONLY DURING
SANDING/ABRADING OF THE DRIED FILM.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:<0-395F
Vapor Density:>1
Evaporation Rate & Reference:FASTER THAN ETHER
Percent Volatiles by Volume:>60
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO & CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THIS PRODUCT MAY BE HAZARDOUS AS
DEFINED UNDER RCRA. WASTE MUST BE TESTED FOR IGNITABILITY TO
DETERMINE APPLICABLE EPA HAZARDOUS WASTE NUMBERS. DON'T INCINERATE.
DEPRESSURIZE CONTAINER. DIS POSE OF IAW FEDERAL/STATE/LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:POTASSIUM HYDROXIDE
CAGE:63415
CAGE:63415
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: >85%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C, 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RAT:365MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:ACUTE:SEVERE IRRITATION/BURNS OF EYES,
SKIN AND RESPIRATORY OR GI TRACT,SEVERE REDNESS OF EYES,BLURRED
VISION. CHRONIC: LUNGS OR G.I. TRACT DAMAGE,DERMATITIS;CORROSIVE TO
ALL BODY TISSUE.
Effects of Overexposure:SEE HEALTH HAZARDS DATA.
Medical Cond Aggravated by Exposure:PRE-EXISTING CONDITIONS MAY BE
WORSEN.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR;SEE MEDICAL HELP IMMEDIATELY.
EYES:FLUSH WITH PLENTY OF WATER FOR 15 MINUTES,CALL A PHYSICIAN AT
ONCE. SKIN:WASH WITH LARGE AMOUNTS OF WATER. INGESTION:SEEK MEDICAL
HELP IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:DRY CHEMICAL,CO2,FOAM,WATER SPRAY.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA IN AN ENCLOSED
AREA.
Unusual Fire/Explosion Hazard:NEGLIGIBLE FIRE OR EXPLOSION HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;COLLECT SOLID
MATERIAL IN AIR TIGHT CONTAINER OR DILUTE WITH WATER,USE SUITABLE
INERT ABSORBENT MATERIAL & RECOVER FOR PROPER DISPOSAL.WASH THE
SURFACE WITH PLENTY OF WA TER.
Neutralizing Agent:DIL,ACIDS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY AREA.KEEP AWAY FROM
OXIDIZERS & ACIDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED SCBA OR RESPIRATOR FOR
VAPORS/MIST IF ABOVE TLV/PEL.
Ventilation:LOCAL EXHAUST/GENERAL TO MAINTAIN PEL/TLV.
Other Protective Equipment:EYE-WASH,SAFETY SHOWER,FULL SKIN AND EYE
PROTECTION.
Work Hygienic Practices:AVOID CONTACT WITH EYES AND SKIN;DO NOT BREATHE
VAPORS/MIST WASH THOROUGHLY AFTER EACH USE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:B1
Boiling Pt:=1320.C, 2408.F
Melt/Freeze Pt:=361.C, 681.8F
Spec Gravity:2.044
pH:13.5
Solubility in Water:COMPLETE
Appearance and Odor:HYGROSCOPIC, ODORLESS, WHITE OR SLIGHTLY YELLOW
LUMPS, RODS, PELLETS, OR FLAKES
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZER, ACID/METALS.
Stability Condition to Avoid:WATER/EXTREME HEAT.
Hazardous Decomposition Products:HEAT,FLAMMABLE HYDROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF COLLECTED MATERIAL IN ACCORDANCE WITH
LOCAL,STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PRESENCE/ABSENCE BROTH WITH MUG, DISPOSAL
Resp. Party Other MSDS Num.:M00896
CAGE:91224
CAGE:91224
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM CHLORIDE
CAS:7647-14-5
RTECS #:VZ4725000
< Wt:5.
Other REC Limits:LD50 ORAL RAT=3G/KG
Ingred Name:PEPTONES
CAS:73049-73-7
< Wt:5.
Ingred Name:BEEF EXTRACT
< Wt:5.
Ingred Name:LACTOSE
CAS:63-42-3
RTECS #:OD9625000
Minumum % Wt:1.
Maxumum % Wt:10.
Ingred Name:WATER (DEMINERALIZED)
CAS:7732-18-5
RTECS #:ZC0110000
Minumum % Wt:60.
Maxumum % Wt:70.
Ingred Name:OTHER COMPONENTS, EACH
< Wt:1.
Ingred Name:TRYPTOSE (9015-54-7)
Minumum % Wt:1.
Maxumum % Wt:10.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: NO EFFECTS ARE ANTICIPATED. SKIN:
NO EFFECTS ARE ANTICIPATED. INGESTION: PRACTICALLY NON-TOXIC.
INHALATION: NO EFFECTS ANTICIPATED. CHRONIC EFFECTS: NO EFFECTS
ANTICIPATED.
Explanation of Carcinogenicity:THIS PRODUCT DOES NOT CONTAIN ANY OSHA
LISTED CARCINOGENS. THIS PRODUCT DOES NOT CONTAIN ANY IARC AND NTP
LISTED CHEMICALS.
Effects of Overexposure:NONE ANTICIPATED.
Medical Cond Aggravated by Exposure:NONE REPORTED.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH EYES WITH WATER. CALL PHYSICIAN IF IRRITATION
DEVELOPS. SKIN: WASH SKIN WITH PLENTY OF WATER. INGESTION: GIVE
LARGE QUANTITIES OF WATER. CALL PHYSICIAN IMMEDIATELY. INHALATION:
NONE REQUIRE D.
===================== Fire Fighting Measures =====================
Flash Point:WILL NOT BURN
Extinguishing Media:USE MEDIA APPROPRIATE TO SURROUNDING FIRE
CONDITIONS.
Fire Fighting Procedures:AS IN ANY FIRE, WEAR SELF-CONTAINED BREATHING
APPARATUS PRESSURE-DEMAND AND FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:THIS PRODUCT WILL NOT BURN OR EXPLODE.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP SPILLED MATERIAL FROM BEING RELEASED TO
THE ENVIRONMENT. ABSORB SPILLED LIQUID WITH NON-REACTIVE SORBENT
MATERIAL. CLEANUP OF USED PRODUCT: STERILIZE WITH BLEACH OR BY
AUTOCLAVING. PLACE MATERIAL IN A PLASTIC BAG. MARK BAG
'NON-HAZARDOUS TRASH', AND DISPOSE OF AS NORMAL REFUSE.
DECONTAMINATE AREA WTH BLEACH SOLUTION.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH EYES. WASH
THOROUGHLY AFTER HANDLING. MAINTAIN GENERAL INDUSTRIAL HYGIENE
PRACTICES WHEN USING THIS PRODUCT. STORE IN THE DARK BETWEEN 2C -
25C.
Other Precautions:ONLY PERSONS PROPERLY QUALIFIED TO RESPOND TO AN
EMERGENCY INVOLVING HAZARDOUS SUBSTANCES MAY RESPOND TO A SPILL
ACCORDING TO FEDERAL REGULATION (OSHA 29 CFR 1910.120(A)(V) AND PER
YOUR COMPANY'S EMER GENCY RESPONSE PLAN AND GUIDELINES/PROCEDURES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ADEQUATE VENTILATION.
Ventilation:MAINTAIN GENERAL INDUSTRIAL HYGIENE PRACTICES WHEN USING
THIS PRODUCT.
Work Hygienic Practices:AVOID CONTACT WITH EYES. WASH THOROUGHLY AFTER
HANDLING. PROTECT FROM LIGHT.
Supplemental Safety and Health
CATALOG NUMBER: 2401650.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:=100.C, 212.F
Vapor Pres:NOT DETERMINED
Spec Gravity:NOT DETERMINED
pH:6.9
Evaporation Rate & Reference:NOT DETERMINED
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR, RED-PURPLE LIQUID; ODOR NOT DETERMINED.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE REPORTED.
Stability Condition to Avoid:BACTERIAL CONTAMINATION. EXPOSURE TO
DIRECT SUNLIGHT. HEAT.
Hazardous Decomposition Products:NO HAZARDOUS DECOMPOSITION PRODUCTS
KNOWN.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:PRODUCT TOXICOLOGICAL DATA: LD50, LC50 = NONE
REPORTED. SKIN, EYE IRRITATION DATA= NONE REPORTED. DERMAL TOXICITY
DATA= NONE REPORTED. MUTATION DATA = NONE REPORTED. REPRODUCTIVE
TOXICITY: IN A LOBORA TORY TEST, MICE GIVEN 2% NACL SOLUTION IN
PLACE OF DRINKING WATER DURING PREGNANCY PRODUCED HYPERTENSIVE
ADULT OFFSPRING. A SINGLE SUCUTANEOUS INJECTION OF NACL SOLUTION
INTO PREGNANT MICE @2500 MG/KG CAUSED FETAL DEATHS AND
MALFORMATION. INGREDIENT TOXI DATA: LACTOSE ORAL RAT TLDL0= 375
MG.KG; NACL ORAL RAT LD50= 3000 MG/KG.
===================== Ecological Information =====================
Ecological:NO ECOLOGICAL DATA AVAILABLE FOR THIS PRODUCT AND ITS
INGREDIENTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:USED PRODUCT-STERILIZE WITH BLEACH OR BY
AUTOCLAVING. UNUSED PRODUCT-MAKE SURE TUBES ARE TIGHTLY CAPPED.
PLACE MATERIAL IN A PLASTIC BAG. MARK BAG 'NON-HAZARDOUS TRASH,'
AND DISPOSE OF AS NORMAL REFU SE. EMPTY CONTAINERS: RINSE THREE
TIMES WITH AN APPROPRIATE SOLVENT. DISPOSE OF EMPTY CONTAINER AS N
ORMAL TRASH. FOLLOW ALL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:NOT REGULATED FOR TRANSPORTATION.
===================== Regulatory Information =====================
SARA Title III Information:SEC 311/312: NOT COVERED. SEC 313 (40 CFR
372): DOES NOT CONTAIN ANY CHEMICAL SUBJECT TO THE REPORTING
REQUIREMENTS OF SEC 313. SEC 302 (EHS) TPQ, RQ (40 CFR 355): NOT
APPLICABLE. SEC 304 CERCLA RQ ( 40 CFR 302.4 : NOT APPLICABLE.
CLEAN WATER ACT (40 CFR 116.4): NOT APPLICABLE.
Federal Regulatory Information:OSHA: THIS PRODUCT DOES NOT MEET THE
CRITERIA FOR A HAZARDOUS SUBSTANCE AS DEFINED IN THE HAZCOM
STANDARD ( 29 CFR 1910.1200). TSCA: ALL INGREDIENTS ARE LISTED ON
THE TSCA 8(B) INVENTORY (40CFR 710).
State Regulatory Information:CALIFORNIA PROPOSITION 65: NO LISTED
CHEMICALS ARE PRESENT.
======================= Other Information =======================
======================================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1000-112 ORTHO HI POWER BRAND INDOOR INSECT FOGGER
CAGE:SOLAR
CAGE:SOLAR
============= Composition/Information on Ingredients =============
Ingred Name:PYRETHRINS
CAS:8003-34-7
RTECS #:UR4200000
Fraction by Wt: 0.05%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:PERMETHRIN
CAS:52645-53-1
RTECS #:GZ1255000
Fraction by Wt: 0.4%
ACGIH TLV:NOT EST.
Ingred Name:N-OCTYL BICYCLOHEPTENE DICARBOXIMIDE, MGK-264
CAS:463-04-7
RTECS #:RB8575000
Fraction by Wt: 0.4%
Ingred Name:INERT INGREDIENTS (TYPE NOT SPECIFIED)
Fraction by Wt: 99.15%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(LAB ANIMAL): 5 GM/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MAY CAUSE IRRITATION. SKIN: IF
ABSORBED, NON-TOXIC TO INTERNAL ORGANS. INGESTION: SLIGHTLY TOXIC,
CAN ALSO CAUSE NERVOUS SYSTEM DISORDERS. INHALATION: SLIGHTLY
TOXIC, CAN CAUSE NASAL & RESPIRATO RY IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:DISCOMFORT, TEARING, SWELLING, REDNESS, BLURRED
VISION, RASH, GI DISCOMFORT, NAUSEA, VOMITING, DIARRHEA, FATIGUE,
DIZZINESS, HEADACHES, LACK OF COORDINATION, TREMORS,
UNCONSCIOUSNESS, IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMEDIATELY W/FRESH WATER FOR 15 MINS. REMOVE
CONTACT LENSES. SKIN: WASH W/PLENTY OF SOAP & WATER. INGESTION:
DRINK 1/2 GLASSES OF WATER & INDUCE VOMITING BY TOUCHING THE BACK
OF THE THROA T W/FINGER. DON'T INDUCE VOMITING/GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS PERSON. INHALATION: REMOVE TO FRESH AIR.
GIVE CPR IF NEEDED. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:165F
Extinguishing Media:ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:AVOID BREATHING SMOKE & MISTS. AVOID CONTACT
W/FALLOUT & RUNOFF. MINIMIZE THE AMOUNT OF WATER USED FOR FIRE
FIGHTING. (SEE SUPP)
Unusual Fire/Explosion Hazard:SMOKE FROM FIRES INVOLVING THIS MATERIAL
MAY PRESENT UNUSUAL HAZARDS.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: SOAK UP MATERIAL W/PAPER TOWELS &
DISCARD IN TRASH. LARGE: ELIMINATE SOURCES OF IGNITION/RELEASED
VAPOR. CONTAINED/DIKED ABSORBED W/ATTAPULGITE, BENTONITE/OTHER
ABSORBENT MATERIAL. COLLECT & PL ACE IN PLASTIC LINED METAL DRUM &
DISPOSE.(SEE SUP
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A SECURE, PREFERABLY LOCKED,
COOL DRY STORAGE AREA AWAY FROM HEAT, OPEN FLAME & DIRECT SUNLIGHT.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. DON'T BREATH
VAPOR/SPRAY MIST. AVOID CONTACT W/EYES, SKIN/CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL RESPIRATORY PROTECTION IS REQUIRED.
Ventilation:REQUIRED
Other Protective Equipment:WEAR PROTECTIVE CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THROUGHLY W/SOAP & WATER AFTER HANDLING.
Supplemental Safety and Health
FIRE PROC CONT'D: DON'T ENTER ANY ENCLOSED AREA W/OUT FULL PROTECTIVE
EQUIPMENT & SCBA. CONTAIN & ISOLATE RUNOFF & DEBRIS FOR PROPER
DISPOSAL. SPILLS: THOROUGHLY SCRUB FLOOR/IMPERVIOUS SURFACE W/A STR
ONG INDUSTRIAL TYPE DETERGENT SOLUTION & RINSE W/WATER. DON'T
CONTAMINATE WATER, FOODSTUFFS/FEED BY STORAGE/DISPOSAL.
================== Physical/Chemical Properties ==================
Spec Gravity:0.975
pH:6.75
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR LIGHT YELLOW LIQUID IN AEROSOL CONTAINER
W/SLIGHT SOLVENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, CHLORATES, NITRATES, PEROXIDES.
Stability Condition to Avoid:TEMPS > 130F, HEAT, OPEN FLAME, DIRECT
SUNLIGHT.
Hazardous Decomposition Products:HEAT/STRONG OXIDIZERS, CHLORINE &
HYDROGEN CHLORIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:LARGE: IF NECESSARY TO DISPOSE OF PARTIALLY
FILLED PRODUCT CONTAINERS, THEN REPLACE CAP DISCARD IN THE TRASH.
DON'T INCINERATE, PUNCTURE/DISCARD IN HOME TRASH COMPACTOR. DISPOSE
OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:50% LEL ACETYLENE IN AIR
CAGE:DO808
CAGE:51906
CAGE:DO808
============= Composition/Information on Ingredients =============
Ingred Name:AIR
Fraction by Wt: 99%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACETYLENE
CAS:74-86-2
RTECS #:AO9600000
Fraction by Wt: 1%
OSHA PEL:N/K
ACGIH TLV:SIMPLE ASPHYXIANT
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE O2/ARTF RESP
. INGEST: CALL MD IMMED . EYE: IMMED FLUSH WITH POTABLE WATER FOR A
MINIMUM OF 15 MIN, SEEK ASSISTANCE FROM MD . SKIN: FL USH WITH
COPIOUS AMOUNTS OF WATER. CALLMD .
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:NO SPECIAL PRECAUTIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY AREA. DO NOT
PUNCTURE CYLINDER. EXPOSURE TO TEMPERATURES ABOVE 150F MAY OPERATE
EXCESS PRESSURE VALVE.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED. USE NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Other Protective Equipment:NONE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:G3
Boiling Pt:B.P. Text:GAS
Vapor Pres:GAS
Vapor Density:1
Solubility in Water:SLIGHT
Appearance and Odor:COLORLESS, VERY SLIGHT GARLIC-LIKE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSIPATE CONTENTS IN WELL-VENTILATED AREA,
DISCARD CONTAINER AS ANY NORMAL METAL REFUSE. DO NOT INCINERATE.
DISPOSE OF I/A/W FEDERAL, STATE AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DREW ELECTRIC MOTOR & PARTS CLEANER
CAGE:HO393
CAGE:HO393
CAGE:52454
============= Composition/Information on Ingredients =============
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 90-95%
Other REC Limits:N/K
OSHA PEL:350 PPM/450 STEL
ACGIH TLV:350 PPM/450STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:PROPRIETARY INHIBITOR PACKAGE (CONTAINED IN INGREDIENT NO
1)
Fraction by Wt:
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:1,4-DIOXANE (DIETHYLENE DIOXIDE) (SARA III)
CAS:123-91-1
RTECS #:JG8225000
Fraction by Wt:
Other REC Limits:N/K
OSHA PEL:S, 100 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:1,1,1-TRICHLOROETHANE CAUSES
PROARRHYTHMIC ACTIVITY WHICH SENSITIZES HEART TO
EPINEPHRINE-INDUCED ARRHYTHMIAS.(RAPID GUIDE TO HAZ CHEM IN
WKPLACE, I. SAX, 1986) . OVEREXP TO PROD HAS BEEN FD TO CAUSE
LIVER ABNORM,KIDNEY DMG&LUNG DMG IN LAB ANIMALS & HAS BEEN SUGGEST
AS CAUSE OF CARDIAC ABNORM,LIVER (SEE SUPP DAT)
Explanation of Carcinogenicity:1,4 DIOXANE:NTP:ANTICIPATED
CARCINOGEN.IARC:PROBABLE HUMAN CARCINOGEN(GP 2B).. NTP & IARC
ANIMAL CARCINOGEN (MFR).
Effects of Overexposure:EYES:CAN CAUSE SEV IRRIT, REDNESS, TEARING,
BLURRED VISION. SKIN:PRLNG/RPTD CONT CAN CAUSE MOD IRRIT, DEFAT,
DERMAT. INHALATION:EXCSV INHAL OF VAPORS CAN CAUSE NASAL & RESP
IRRIT, DIZZ, WEAK, FATG, NA US, HDCH, POSSIBLE UNCON & EVEN
ASPHYXIATION. INGESTION:CAN CAUSE GASTROINTESTINAL IRRIT, NAUSEA,
VOMITING & DIARRHEA.
Medical Cond Aggravated by Exposure:N/K
======================= First Aid Measures =======================
First Aid:SKIN:THOROUGH WASH EXP AREA W/SOAP&H*2O.RMV CONTAM CLTHG &
LAUNDER BFR RE-USE.EYES:FL W/LGE AMT OF H*2O FOR 15 MIN,LFT UPR&LWR
LIDS OCCASION,GET MED ATTN.INGEST:DO NOT INDUCE VOMIT.CALL MD OR
TRANSPOR T TO EMER FACILITY.INHAL:RMV AFFECT INDV TO FRESH AIR.IF
BRTHING IS DIFF ADMIN O*2.IF BRTHING HAS STOPPED GIVE ARTF
RESP.KEEP PER WARM,QUIET & GET MED ATTN.DO NOT GIVE
STIMULANTS.EPHEDRINE/(SUPP DATA)
===================== Fire Fighting Measures =====================
Lower Limits:7.5
Upper Limits:N/K
Extinguishing Media:WATER FOG
Fire Fighting Procedures:USE NIOSH/MSHA APVD PRESS DEMAND SCBA & FULL
PROT EQPT. H*2O MAY BE USED TO KEEP FIRE-EXPOSED CONTAINERS COOL
UNTIL FIRE IS OUT.
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE HCL & PHOSGENE . NEVER USE WELD OR CUT TORCH ON OR NEAR
DRUM (EVEN EMPTY) SINCE PRODUCT CAN IGNITE EXPLOSIVELY.
================== Accidental Release Measures ==================
Spill Release Procedures:SM SPILL:ABSORB LIQ ON PPR, VERMICULITE, FL
ABSORB OR OTHER ABSORB MATL & XFR TO HOOD. LGE SPILL:EXCL PER NOT
WRG PROT EQPT UNTIL CLEAN-UP COMPL. STOP SPILL AT SCE, DIKE AREA TO
PVNT SPREAD, PUMP LIQ TO SALV TANK. ABSORB REM MATL & SHOVEL INTO
CNTNR.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PROLONGED CONTACT W/PLASTIC &
RUBBER SUCH AS EQUIPMENT, PROTECTIVE CLOTHING, & CONTAINERS.
Other Precautions:NO SMKING IN AREA OF USE.DO NOT USE IN GENL VICINITY
OF ARC WELD,OPEN FLAME OR HOT SURF.HEAT &/OR UV RADN MAY CAUSE
FORMATION OF HCL &/OR PHOSGENE .CNTNR OF THIS MATL MAY BE HAZ WHEN
EMPTIED SIN CE EMPTY CNTNR RETAIN PROD(SEE SUPP DAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV OF PROD OR ANY CMPNT IS EXCEEDED, A
NIOSH/MSHA JOINTLY APVD AIR SUPPLIED RSPTR IS ADVS IN ABSENCE OF
PROPER ENVIR CONT. OSHA REGULATIONS ALSO PERMIT OTHER NIOSH/MSHA
RSPTR UNDER SPECIFIED CONDT N. (SEE YOUR SAFETY EQPT SUPPLIER).
Ventilation:PROV SUF MECH (GENL &/OR LCL EXH) VENT TO MAINTAIN EXPSR
BLW TLVS. ENGRG OR ADMIN CONT SHOULD BE IMPL TO RDC EXPSR.
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING & BOOTS.
Work Hygienic Practices:N/K
Supplemental Safety and Health
BP:(72-88C). SPEC GRAV AT 77F (25C). PH&CARC:FP N. MATL TO AVOID:OF
PHOSGENE & CL. STRG OXD AGT. HEALTH HAZ:ABNORM,KIDNEY DMG & LUNG
DMG IN HUMANS. FIRS AID:EPINEPHRINE MAY ADVERSELY AFFECT HEART W/FA
TAL RESULTS. OTHER PREC:RESIDUES(VAPOR,LIQ,&/OR SOLID), ALL HAZ
PREC GIVEN MUST BE OBSERVED.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:162-190 F
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:100.00
Vapor Density:4.5 AIR=1
Spec Gravity:1.300-1.324
Evaporation Rate & Reference:2.60 ETHYL ETHER=1
Solubility in Water:N/K
Appearance and Odor:CLEAR, APHA COLOR 15 MAX, LIQUID, HOMOGENEOUS
SOLUTION
Percent Volatiles by Volume:100
Corrosion Rate:
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
H*2O,REAC MET SUCH AS AL&MG,OPEN FLAME,WELD ARC,RES HTR,ETC,WHICH CAN
RESULT IN THERM DECOMP RLSE HCL & SM AMT(SUP DATA)
Stability Condition to Avoid:N/K
Hazardous Decomposition Products:HCL,PHOSGENE.MAY FORM TOXIC MATL:CO*2
& CO, HYDROGEN CHLORIDE, PHSOGENE, VARIOUS HYDROCARBONS, ETC.
==================== Disposal Considerations ====================
Waste Disposal Methods:SM SPILL:ALLOW VOLATILE PORTION TO EVAP IN HOOD
ALLOW SUF TIME FOR VAPORS TO COMPL CLEAR HOOD DUCT WK.DISPOSE OF
REM MATL IN A/W APPL REG.LGE SPILL:DESTROY BY LIQ INCIN W/OFF GAS
SCRUBBER.DEP CONTAM A BSORB IN LANDFILL IN A/W LCL, STATE & FED
REG.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:GRIPSTONE 220, BS 220
Preparer's Name:MIKE BECKMANN
CAGE:0AHA0
CAGE:0AHA0
============= Composition/Information on Ingredients =============
Ingred Name:UNSATURATED POLYESTER RESIN
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:STYRENE (SARA 313) VP: 4.3 @ 68F
CAS:100-42-5
RTECS #:WL3675000
Fraction by Wt: 15.22%
OSHA PEL:100 PPM
ACGIH TLV:50PPM/100STEL, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (HYDROUS
CALCIUM MAGNESIUM SILICATE MINERAL MIXTURE)
CAS:14807-96-6
RTECS #:WW2710000
OSHA PEL:20 MPPCF Z-3
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:NEPHELINE SYENITE
CAS:37244-96-5
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: NASAL IRRIT, DIZZ, WEAK,
FATG, NAUS, HDCH, POSS UNCON, & EVEN ASPHY. SKIN: PRLNG/RPTD CONT
CAN CAUSE MOD IRRIT, DEFAT, DERM. EYES: CAN CAUSE SEV IRRIT,
REDNESS, TEARING, BLURRED VISION. SKIN ABSORPTION: PRLNG/RPTD CONT
CAN CAUSE MOD IRRIT, DEFAT, DERM. INGEST: CAN CAUSE GI IRRIT, NAUS,
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:STYRENE: IARC MONOGRAPHS, SUPPLEMENT,
VOL 7, PG 345, 1987: GROUP 2B. ANIMAL: NERVOUS SYSTEM.
Effects of Overexposure:HLTH HAZ: VOMIT, DIARR. ASPIR OF MATL INTO
LUNGS CAN CAUSE CHEM PNEUMIT. CHRONIC: OVEREXP TO STYRENE HAS
APPARENTLY BEEN FOUND TO CAUSE THE FOLLOWING EFTS IN LAB ANIMALS:
LIVER ABNORMALITIES, KIDNEY D AMAGE, AND LUNG DAMAGE. STYRENE HAS
ALSO BEEN SHOWN TO BE MUTAGENIC IN SEVERAL "IN VITRO" ASSAYS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN: THORO WASH EXPOSED AREA W/SOAP & WATER. REMOVE CONTAM
CLTHG. EYES: FLUSH W/LGE AMTS OF WATER FOR AT LEAST 15 MIN, LIFTING
UPPER & LOWER LIDS OCCAS. GET MED ATTN. INHAL: IF AFFECTED, REMOVE
INDIV IDUAL TO FRESH AIR. IF BRTHG IS DFCLT, ADMIN OXYGEN. IF BRTHG
HAS STOPPED, GIVE ARTF RESP. KEEP PERS WARM, QUIET, & GET MED ATTN.
INGEST: DO NOT INDUCE VOMIT. KEEP PERS WARM, QUIET, & GET (SUP DAT)
===================== Fire Fighting Measures =====================
Flash Point:88.0F,31.1C
Lower Limits:1.1%
Upper Limits:6.1%
Extinguishing Media:USE FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH APPRVD SCBA AND FULL PROT EQUIP .
WATER/FOAM MAY CAUSE FROTHING WHICH CAN BE VIOLENT & POSS ENDANGER
LIFE OF FIREFIGHTER, ESP IF (SUP DAT)
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & MAY TRAVEL ALONG
GROUND/BE MOVED BY VENT & IGNITED BY PILOT LIGHTS, OTHER FLAMES,
SPARKS, HEATERS, SMKNG, ELEC MOTORS, STATIC (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. PERSONS NOT
WEARING PROTECTIVE EQUIPMENT SHOULD BE EXCLUDED FROM AREA OF SPILL.
STOP SPILL AT SOURCE, DIKE AREA TO PREVENT SPREADING, PUMP LIQUID
TO SALVAGE TANK. ABSOR B REMAINING LIQUID ON ABSORBENT MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTAINERS OF THIS MATERIAL MAY BE
HAZARDOUS WHEN EMPTIED.
Other Precautions:SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES
(VAPORS, LIQUID, AND/OR SOLID), ALL HAZARD PRECAUTIONS GIVEN IN
THIS MSDS MUST BE OBSERVED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPRVD AIR SUPP RESP IS ADVISED IN ABSENCE
OF PROPER ENVIRON CTL. OSHA REGS ALSO PERMIT OTHER NIOSH APPRVD
RESPS UNDER SPECIFIED CNDTNS (SEE YOUR SFTY EQUIP SUPPLIER).
ENGINEERING/ADMIN CTLS SHO ULD BE IMPLEMENTED TO REDUCE EXPOS.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV'S.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA . NORMAL WORK CLOTHING COVERING ARMS AND LEGS.
Work Hygienic Practices:THOROUGHLY WASH HANDS BEFORE EATING, DRINKING,
SMOKING, OR USING THE WASHROOM.
Supplemental Safety and Health
FIRE FIGHT PROC: SPRAYED INTO CONTRS OF HOT, BURNING LIQ. EXPLO HAZ:
DISCHARGE/OTHER IGNIT SOURCES AT LOCATIONS DISTANT FROM MATL HNDLG
POINT. NEVER USE WELDING/CUTTING TORCH ON/NEAR DRUM BECAUSE PROD
CAN IGNITE EXPLO. FIRST AID PROC: MED ATTN. ASPIR OF MATL INTO
LUNGS DUE TO VOMIT CAN CAUSE CHEM PNEUMIT--CAN BE FATAL.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>293F,>145C
Vapor Pres:SEE ING 2
Vapor Density:HVR/AIR
Spec Gravity:1.6 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:PASTE WITH VARIOUS STONE COLORATION AND STYRENE
ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, STRONG MINERAL ACIDS, AND OXIDIZING AGENTS.
Stability Condition to Avoid:EXPOSURE TO EXCESSIVE HEAT/OPEN FLAMES;
STORAGE IN OPEN CONTAINERS; STORAGE ABOVE 100F; CONTAMINATION
W/OXIDIZERS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, LOW
MOLECULAR WEIGHT HYDROCARBONS, ORGANIC ACIDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DESTROY BY LIQUID INCINERATION IN ACCORDANCE
WITH APPLICABLE REGULATIONS. CONTAMINATED ABSORBENT MAY BE
DEPOSITED IN A LANDFILL IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:26208
CAGE:73386
CAGE:73386
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR.AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UNC ONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HYDROCHLORIC ACID 1M
CAGE:59896
Contract Num:MDA414-98-A-0118-0127
CAGE:59896
============= Composition/Information on Ingredients =============
Ingred Name:HYDROGEN CHLORIDE (HYDROCHLORIC ACID) (SARA 302/313)
(CERCLA)
CAS:7647-01-0
RTECS #:MW4025000
= Wt:8.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 5 PPM
ACGIH TLV:C 5 PPM; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES-MAY CAUSE IRRITATION. SKIN-MAY
CAUSE IRRITATION. INGESTION-MAY CAUSE GASTROINTESTINAL DISCOMFORT.
INHALATION-MAY CAUSE IRRITATION TO RESPIRATORY TRACT.
Explanation of Carcinogenicity:TEST ON LABORATORY ANIMALS INDICATE
MATERIAL MAY PRODUCE ADVERSE MUTAGENIC AND REPRODUCTIVE EFFECTS.
Effects of Overexposure:CAUSES SEVERE BURNS.
Medical Cond Aggravated by Exposure:RESPIRATORY CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYES-FLUSH WITH WATER FOR 15 MINS, RAISING & LOWERING EYELIDS
OCCASIONALLY. GET MEDICAL AID IF IRRITATION PERSISTS.
SKIN-THOROUGHLY WASH EXPOSED AREA FOR 15 MIN. REMOVE CONTAMINATED
CLOTHES. LAUNDER C ONTAMINATED CLOTHING BEFORE REUSE. GET MEDICAL
AID IF IRRITATION PERSISTS. INGESTION-DO NOT INDUCE VOMITING. IF
SWALLOWED, IF CONSCIOUS, GIVE PLENTY OF WATER. IMMEDIATELY CALL A
PHYSICIAN OR POISON CO NTROL CENTER. NEVER GIVE ANYTHING BY MOUTH
TO AN UNCONSCIOUS PERSON. INHALATION-REMOVE TO FRESH AIR. GIVE
OXYGEN IF BREATHING IS DIFFICULT; GIVE ARTIFICIAL RESPIRATION IF
BREATHING HAS STOPPED. KEEP P ERSON WARM, QUIET, & GET MEDICAL AID.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR FULL PROTECTIVE
EQUIPMENT AND NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE CITED.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA OF SPILL. ELIMINATE ALL SOURCES
OF IGNITION. REMOVE ALL NON-ESSENTIAL PERSONNEL FROM AREA. CLEAN-UP
PERSONNEL SHOULD WEAR PROPER PROTECTIVE EQUIPMENT/CLOTHING. ABSORB
MATERIAL WITH SUIT ABLE ABSORBENT & CONTAINERIZE FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED IN A
COOL, WELL VENTILATED AREA AWAY FROM INCOMPATIBLE MATERIALS.
Other Precautions:HANDLE EMPTY CONTAINERS WITH CAUTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH/MSHA CHEMICAL CARTRIDGE RESPIRATOR
SHOULD BE WORN IF PEL OR TLV IS EXCEEDED.
Ventilation:LOCAL EXHAUST AND MECHANICAL (GENERAL) VENTILATION.
Other Protective Equipment:LAB COAT, EYE WASH AND SAFETY SHOWER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:=110.C, 230.F
Melt/Freeze Pt:=-74.C, -101.2F
Vapor Pres:160
Vapor Density:1.25
Spec Gravity:1.1885
Evaporation Rate & Reference:2.0 (N-BUTYL ACETATE=1)
Solubility in Water:MISCIBLE.
Appearance and Odor:CLEAR, COLORLESS LIQUID WITH AN ACRID ODOR.
Percent Volatiles by Volume:>99.9
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BASES, ALKALIES AND AMINES.
Stability Condition to Avoid:HEAT, CONTACT WITH METALS.
Hazardous Decomposition Products:TOXIC HYDROGEN CHLORIDE GAS.
=================== Toxicological Information===================
Toxicological Information:IHL-HMN LDLO: 1300 PPM/30M.
===================== Ecological Information =====================
Ecological:EPA WASTE NUMBER: D002.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL REGULATIONS. ALWAYS CONTACT A PERMITTED
WASTE DISPOSER (TSD) TO ASSURE COMPLIANCE.
=================== MSDS Transport Information ===================
Transport Information:HYDROCHLORIC ACID, SOLUTION.
===================== Regulatory Information =====================
SARA Title III Information:SARA SECTION 313, HYDROCHLORIC ACID, YES,
500 TPQ. HAZARD CATEGORY FOR SARA SECTION 311/312 REPORTING: ACUTE.
Federal Regulatory Information:CERCLA SEC. 103, RQ LBS: 5000. ON TSCA
INVENTORY.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ACETONE, A949SS50
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE; (2-PROPANONE) (SARA 313) (CERCLA). LD50: (ORAL,
RAT) 5800 MG/KG.
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 99%
OSHA PEL:1000 PPM
ACGIH TLV:750 PPM; 1000 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:FIRST AID PROC: TO FRESH AIR IMMED. IF NOT BRTHG, GIVE ARTF
RESP. IF BRTHG IS DFCLT, GIVE OXYGEN. NOTES TO MD: (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2: TREAT SYMPTOMATICALLY & SUPPORTIVELY.
RTECS #:9999999ZZ
Ingred Name:OTHER PRECS: SOLDER, DRILL, GRIND OR EXPOSE EMPTY
CONTAINERS TO HEAT, SPARKS OR OPEN FLAMES.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: PRDCES IRRIT CHARACTERIZED BY
BURNING SENSATION, REDNESS, TEARING, INFLAMMATION & POSS CORNEAL
INJURY. SKIN: EXPOS MAY CAUSE IRRIT CHARACTERIZED BY REDNESS,
DRYNESS & INFLAMMATION. INGEST: MAY C AUSE IRRIT OF DIGESTIVE
TRACT. MAY CAUSE CNS DEPRESS, KIDNEY DMG & LIVER DMG. SYMPS MAY
INCL: HDCH, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: EXCITEMENT, FATIGUE, NAUS, VOMIT,
STUPOR & COMA. INHAL: INHAL OF HIGH CONCS MAY CAUSE CNS EFTS
CHARACTERIZED BY HDCH, DIZZ, UNCON & COMA. CAUSES RESP TRACT IRRIT.
MAY CAUSE LIVER & KIDNEY DM G. MAY CAUSE MOTOR INCOORD & SPEECH
ABNORMS. CHRONIC: PRLNGD/RPTD SKIN CONTACT MAY CAUSE DERMATITIS.
CHRONIC (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH EYES W/PLENTY OF WATER FOR AT LEAST 15 MIN
OCCASNLY LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. SKIN: FLUSH
SKIN W/PLENTY OF SOAP & WATER FOR AT LEAST 15 MIN WHILE REMOVING
CONTAM CLTHG & SHOES. GET MED AID IF IRRIT DEVELOPSOR PERSISTS.
INGEST: IF VICTIM IS CONSCIOUS & ALERT, GIVE 2-4 CUPFULS OF MILK OR
WATER. GET MED AID IMMED. INHAL: GET MED AID IMMED. REMOVE FROM
EXPOS (ING 2)
===================== Fire Fighting Measures =====================
Flash Point:-4F,-20C
Lower Limits:2.5%
Upper Limits:12.8%
Extinguishing Media:FOR SMALL FIRES, USE DRY CHEMICAL, CARBON DIOXIDE,
WATER SPRAY OR ALCOHOL-RESISTANT FOAM. FOR LARGE FIRES, USE
(SUPDAT)
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CNTNRS CAN BUILD UP PRESSURE IF EXPOSED
TO HEAT &/OR FIRE. VAPS CAN TRAVEL TO SOURCE OF IGNITION & FLASH
BACK. USE WATER SPRAY TO KEEP FIRE-EXPOSED CNTNRS COOL.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SPILL WITH INERT MATERIAL (EG, DRY SAND
OR EARTH), THEN PLACE INTO A CHEMICAL WASTE CONTAINER. WEAR
APPROPRIATE PROTECTIVE CLOTHING TO MINIMIZE CONTACT WITH SKIN.
REMOVE ALL SOURCES OF IGNITION .
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM SOURCES OF IGNITION.
STORE IN A TIGHTLY CLOSED CONTAINER.
Other Precautions:WASH THOROUGHLY AFTER HNDLG. REMOVE CONTAM CLTHG &
WASH BEFORE REUSE. USE W/ADEQ VENT. AVOID CONTACT W/EYES, SKIN &
CLTHG. EMPTY CNTNRS RETAIN PROD RESIDUE (LIQ &/OR VAP) & CAN BE
DANGEROUS. DO NOT PR ESSURIZE, CUT, WELD, BRAZE, (ING 4)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
29 CFR 1910.134 OR EUROPEAN STANDARD EN 149. ALWAYS USE A NIOSH OR
EUROPEAN STANDARD EN 149 APPROVED RESPIRATOR WHEN NECESSARY.
Ventilation:USE PROCESS ENCLOSURE, LOC EXHST VENT OR OTHER ENGINEERING
CONTROLS TO CONTROL AIRBORNE LEVELS BELOW RECOM EXPOS LIMITS.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN EXPOSURE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXTING MEDIA: WATER SPRAY, FOG OR ALCOHOL-RESISTANT FOAM. MATLS TO
AVOID: ANHYDRIDE, CHROMYL CHLORIDE, NITROSYL CHLORIDE,
HEXACHLOROMELAMINE, NITROSYL PERCHLORATE, NITRYL PERCHLORATE,
PERMONOSULFURIC ACID, THIODIGLYCOL + HYDROGEN PEROXIDE.EFTS OF
OVEREXP: INHAL MAY CAUSE EFTS SIMILAR TO THOSE OF ACUTE INHAL.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:133F,56C
Melt/Freeze Pt:M.P/F.P Text:-140F,-95C
Vapor Pres:180
Vapor Density:2.0
Spec Gravity:0.79 (H*2O=1)
pH:7
Evaporation Rate & Reference:7.7 (N-BUTYL ACETATE=1)
Solubility in Water:SOLUBLE
Appearance and Odor:COLORLESS LIQUID; SWEETISH ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
FORMS EXPLOSIVE MIXTURE W/HYDROGEN PEROXIDE, ACETIC ACID, NITRIC ACID,
NITRIC ACID + SULFURIC ACID, CHROMIC (SUPDAT)
Stability Condition to Avoid:HIGH TEMPERATURES, TEMPERATURES ABOVE
220C.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE AND LOCAL REGULATIONS. RCRA U SERIES: CAS #67-64-1: WASTE
NUMBER U002 (IGNITABLE WASTE).
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1-METHYL-2-PYRROLIDONE, 69118
CAGE:21076
CAGE:21076
============= Composition/Information on Ingredients =============
Ingred Name:2-PYRROLIDINONE, 1-METHYL-; (1-METHYL-2-PYRROLIDONE)
CAS:872-50-4
RTECS #:UY5790000
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT) 3914 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:HARMFUL IF SWALLOWED, INHALED OR
ABSORBED THROUGH SKIN. VAPOR IS IRRITATING TO THE EYES, MUCOUS
MEMBRANES AND UPPER RESPIRATORY TRACT. CAUSES SKIN IRRITATION.
PROLONGED EXPOSURE CAN CAUSE STOMAC H PAINS, VOMITING, DIARRHEA.
CHRONIC:OVEREXPOSURE MAY CAUSE REPRODUCTIVE DISORDER(S) BASED ON
TESTS W/ (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:LAB ANIMALS. TARGET ORGANS:BONE
MARROW, THYMUS, SPLEEN, LYMPHATIC SYSTEM. RATS EXPOSED TO
1-METHYL-2-PYRROLIDINONE AT CONC OF 1 MG/L AS AN AEROSOL FOR 10
DAYS SHOWED DEPLETION OF HEMATOPOIETI C CELLS IN BONE MARROW &
ATROPHY OF LYMPHOID TISSUES OF THE THYMUS, SPLEEN & LYMPH NODES.
TARGET ORGAN DATA:EFTS(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:IMMED FLUSH W/COPIOUS AMTS OF WATER FOR AT LST 15 MINS.
ASSURE ADEQ FLUSHING BY SEPARATING EYELIDS W/FINGERS. SKIN:IMMED
FLUSH W/COPIOUS AMTS OF WATER FOR AT LST 15 MINS WHILE REMOVING
CONTAM CLT HG & SHOES. REMOVE & WASH CONTAM CLTHG PROMPTLY. DISCARD
CONTAM SHOES. INHAL:REMOVE TO FRESH AIR. IF NOT BRTHG GIVE ARTF
RESP. IF BRTHG IS DFCLT, GIVE OXYG. INGEST:WASH OUT MOUTH W/WATER
(SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point:187F,86C
Lower Limits:1.3%
Upper Limits:9.5%
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL POWDER OR
APPROPRIATE FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . COMBUSTIBLE LIQUID.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR NIOSH APPROVED SCBA,
PLACE IN CLOSED CONTAINERS FOR DISPOSAL. VENTILATE AREA & WASH
SPILL SITE AFTER MATL PICKUP IS COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT BREATHE VAPOR. AVOID CONTACT
W/EYES, SKIN, & CLOTHING. MAY BE READILY ABSORBED THRU SKIN.
IRRITANT. POSSIBLE TERATOGEN. KEEP TIGHTLY CLOSED.
Other Precautions:KEEP AWAY FROM HEAT & OPEN FLAME. STORE IN A COOL,
DRY PLACE. HARMFUL BY INHAL, IN CONTACT W/SKIN & IF SWALLOWED.
IRRITATING TO EYES, RESP SYSTEM & SKIN. POSSIBLE RISK OF
IRREVERSIBLE EFTS. COMBUSTIBL E. HYGROSCOPIC. STORE UNDER NITROGEN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . WEAR SUITABLE PROTECTIVE CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
VP:0.29 @ 20C; 0.99 @ 40C. EFTS OF OVEREXP:ON FERTILITY
(POST-IMPLANTATION MORTALITY). SPECIFIC DEVELOPMENTAL ABNORMS (CNS,
MUSCULOSKELETAL SYSTEM). FIRST AID PROC:PROVIDED PERSON IS
CONSCIOUS. CALL M D.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>178F,>81C
Melt/Freeze Pt:M.P/F.P Text:-11F,-24C
Vapor Pres:SUPP DATA
Vapor Density:3.4
Spec Gravity:1.033
Appearance and Odor:COLORLESS LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY PRODUCE
CARBON MONOXIDE, CARBON DIOXIDE & NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS COMBUSTIBLE MATERIAL MAY BE BURNED IN A
CHEMICAL INCINERATOR EQUIPPED W/AFTERBURNER & SCRUBBER. OBSERVE ALL
FEDERAL, STATE & LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SILVER SEAM SEALER, BJ-L
CAGE:2L332
CAGE:2L332
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA 313) (CERCLA). BP:230F,110C. VP:38 @ 20C.
EVAP RATE:1.5 (N-BUAC=1). FL PT:45F,7C. LEL:1.2%. UEL:7%.
CAS:108-88-3
RTECS #:XS5250000
OSHA PEL:200 PPM
ACGIH TLV:50 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (VM&P NAPHTHA).
BP:233F;112C. VP:<38 @ 20C. EVAP RATE:1 (N-BUTYL ACETATE=1). (ING
3)
CAS:64742-47-8
RTECS #:OA5504000
OSHA PEL:N/K
ACGIH TLV:300 PPM (MFR)
Ingred Name:ING 2:FL PT:45F,7C. LEL:0.9%. UEL:7%.
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPP DATA:& PRLNG OCCUP OVEREXP TO SOLVS W/PERM BRAIN &
NERV SYS DMG. SYMPS INCL:LOSS OF MEMORY, INTELLECTUAL (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:ABILITY & COORD. NOTE:INTENTIONAL MISUSE BY DELIB
CONC & INHAL SOLV VAPS MAY BE HARMFUL/FATAL! SKIN:EXPOS (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:TO SM AMTS OF SOLV OVER LONG PERIODS OF TIME MAY
CAUSE SOME/ALL OF SYMPS AS IN ACUTE EXPOS TO SOLVS. EYES: (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:SYMPS AS IN ACUTE EXPOS BUT TO A LESSER DEGREE & DMG
NOT LIKELY. INGEST:UNKNOWN. NOTE:TOLUENE APPEARS ON (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:THE NAVY LIST OF OCCUP CHEM REPRO HAZS. SEEK
CONSULTATION FROM APPROP HLTH PROFESSIONALS CONCERNING LATEST (ING
9)
RTECS #:9999999ZZ
Ingred Name:ING 8:HAZARD LIST INFORMATION & SAFE HANDLING & EXPOSURE
INFORMATION .
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:FROM RISK OF FURTHER EXPOS. ADMIN OXYG/ARTF
RESP AS NEEDED. OBTAIN MED ATTN. INGEST:INDUCE VOMIT.(ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:CONSULT MD, HOSPITAL, EMER ROOM/POIS CTL CTR IMMED.
HAVE LIST OF INGS AVAIL. NOTES TO MD:EYES:STAIN FOR (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:EVID OF CORNEAL INJURY. IF CORNEA BURNED, INSTILL
ANTIBIOTIC/STEROID PREPARATION FREQUENTLY. SKIN:TREAT (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:SYMPTOMATICALLY. INHAL:TREAT AS FOR SOLVENT FUME
INHALATION. INGEST:INDUCE VOMITING.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:SOLV VAPS AT CONCS ABOVE
TLV CAN IRRIT RESP TRACT (NOSE, THROAT, LUNGS) CAUSING BURNING
SENSATION, RUNNY NOSE, SORE THROAT, COUGH, CHEST DISCOMFORT
(TIGHTNESS). MAY CAUSE CNS DEPRESS W/FOL LOWING PROGRESSIVE
SYMPS:HDCH, DIZZ, NAUS, STAG GAIT, CONFUSN, UNCON, CESSATION OF
BRTHG & DEATH. SKIN:(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:RPTD/PRLNG CONT W/SOLVS CAN RSLT IN
DRY, DEFATTED & CRACKED CAUSING INCR SUSCEPTIBILITY TO INFECTION.
IRRIT MAY DEVEL INTO CONT DERM. EYE:SOLV FUMES MAY IRRIT
W/RESULTING ITCH, BURNING, REDNE SS. PERM TISS DMG MAY OCCUR IF
SEALANTSARE APPLIED DIRECTLY & NOT FLUSHED OUT IMMED. INGEST:IRRIT
TO MOUTH, & (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFICALLY KNOWN TO MFR, BUT
IT IS POSS THAT EYE, RESP TRACT, SKIN, LIVER, KIDNEY, BLOOD CELL
FORM, NERV SYS & BRAIN DISEASES MAY BE AGGRAVATED BY OVEREXP TO
PRODS ON THIS MSDS.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/CLEAN, LUKEWARM WATER (LOW PRESS) FOR AT LST 15
MINS WHILE LIFTING LIDS. REFER PERS TO MD FOR IMMED ATTN.
SKIN:REMOVE CONTAM CLTHG IMMED. WIPE OFF EXCESS MATL W/RAGS/PAPER
TOWELS. CLEAN W /WATERLESS HAND CLEANER/WASH AFFECTED AREAS THORO
W/SOAP & WATER. WASH CONTAM CLTHG THORO BEFORE REUSE. APPLY SKIN
CREAM IF IRRITATED. SEEK MED ATTN IF IRRIT PERSISTS. INHAL:MOVE TO
AREA FREE (ING 10)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:45.0F,7.2C
Lower Limits:SEE INGS
Upper Limits:SEE INGS
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER FROM FOG NOZZLES MAY BE USED TO COOL CLOSED CNTNRS TO PREVENT
PRESS BUILD-UP (CNTNRS MAY LEAK OR BURST).
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & MAY TRAVEL ALONG
GROUND/BE MOVED BY VENT & IGNITED BY PILOT LIGHTS, OTHER FLAMES,
SPKS, HEATERS, ELEC MOTORS, SMOKING/OTHER IGNIT (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROT EQUIP INCL NIOSH APPRVD RESP PROT.
PVNT FURTHER SPILLAGE. EVACUATE NONESSNTL PERS. REMOVE ALL SOURCES
OF IGNIT & VENT AREA. KEEP SPILL FROM REACHING SEWERS & WATERWAYS.
COLLECT MATL W/NONSPA RKING TOOLS & PUT IN TIGHTLY SEALED
CNTNR.(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STOR TEMP:MIN-50F(10C); MAX-130F(54C).
REC SHELF LIFE:1 YR. KEEP AWAY FROM HEAT, SPKS & OPEN FLAME. DO NOT
INHALE VAPS. AVOID CONT W/SKIN & EYES.
Other Precautions:DO NOT STORE IN TEMPS >130F(54C) OR IN DIRECT
SUNLIGHT. EDUCATE & TRAIN EMPLOYEES IN SAFE USE & HNDLG OF THESE
MATLS AS REQD UNDER OSHA HAZ COMMUNICATION STD (29 CFR 1910.1200).
FOLLOW ALL LBL INSTRUC TIONS. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXHAUST VENT SUFFICIENT TO KEEP AIR-BORNE
CONC OF SOLVS BELOW THEIR RESPECTIVE TLV'S IS NOT POSSIBLE, A NIOSH
APPROVED TC23C RESPIRATOR OR TC-19C AIR SUPPLIED RESP MUST BE USED.
OBSERVE OSHA REGS ( 29 CFR 1910.134) FOR RESPIRATOR USE.
Ventilation:THERE MUST ALWAYS BE ENOUGH VENTILATION TO KEEP VAPOR
CONCENTRATION BELOW LOWER FLAMMABLE LIMIT!
Other Protective Equipment:ANSI APPROVED EYE WASH FOUNTAIN & DELUGE
SHOWER . COVER AS MUCH OF SKIN AS POSSIBLE W/APPROPRIATE CLOTHING.
Work Hygienic Practices:WASH HANDS AFTER USE & BEFORE EATING, DRINKING,
SMOKING OR USING TOILET. CONTACT LENSES SHOULD NOT BE WORN.
Supplemental Safety and Health
EXPLO HAZ:SOURCES AT LOCATIONS FAR FROM MATL BOILING POINT. AT ELEVATED
TEMPS (130F(54C) OR OVER) CNTNRS MAY VENT, RUPTURE/BURST
(CARTRIDGES MAY EXTRUDE THEIR PLUNGERS). SPILL PROC:REMOVE CNTNR TO
SAF E PLACE. EFTS OF OVEREXP:IF SWALLOWED, TO ESOPHAGUS, STOM TISS
& DIGEST TRACT. CHRONIC:INHAL:RPTS HAVE ASSOC RPTD(ING 4)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:SEE INGS
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SEE INGREDIENTS
Solubility in Water:<1% (WT).
Appearance and Odor:ALUM PASTE; MILD SOLVENT ODOR.
Percent Volatiles by Volume:43-48
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:STABLE UNDER NORMAL ROOM CONDITIONS.
Hazardous Decomposition Products:BY HIGH HEAT & FIRE: CARBON DIOXIDE,
CARBON MONOXIDE, HYDROGEN FUMES, SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW ALL FEDERAL, STATE & LOCAL ENVIRONMENTAL
CONTROL REGULATIONS. INCINERATION OF MATERIAL IS PREFERRED METHOD.
CONTAINERS MUST BE HANDLED W/CARE DUE TO FLAMMABLE RESIDUE. RCRA
STATUS:SINCE THESE P RODS ARE IGNITABLE, THEY ARE HAZ WHEN
DISCARDED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SUPER STRIPE TRAFFIC PAINT YELLOW, TYW2D
CAGE:1BF99
CAGE:1BF99
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE (SARA 313) (CERCLA)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 1-5%
OSHA PEL:1000 PPM
ACGIH TLV:750PPM/1000STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHANOL, 2-BUTOXY-; (2-BUTOXYETHANOL)
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 1-5%
OSHA PEL:50 PPM, S
ACGIH TLV:25 PPM, S
Ingred Name:BUTANE
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: 1-2%
OSHA PEL:800 PPM
ACGIH TLV:800 PPM
Ingred Name:ETHYL BENZENE; (ETHYLBENZENE) (SARA 313)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 1-2%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/125STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PROPANE, 2-METHYL-; (ISOBUTANE)
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 15-20%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 5-15%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT
Ingred Name:TOLUENE (SARA 313) (CERCLA)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 10-15%
OSHA PEL:200 PPM
ACGIH TLV:50 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VM & P NAPHTHA
CAS:64742-89-8
Fraction by Wt: 5-15%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:XYLENE (SARA 313) (CERCLA)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 3-10%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:LEAD SULFOCHROME; (LEAD SULFOCHROMATE)
CAS:1344-37-2
Fraction by Wt: 5-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ANTIMONY OXIDE; (ANTIMONY (3+) OXIDE) (SARA 313) (CERCLA)
CAS:1309-64-4
RTECS #:CC5650000
Fraction by Wt: <0.5%
OSHA PEL:0.5 MG (SB)/M3
ACGIH TLV:0.5 MG (SB)/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:MOLYBDATE ORANGE; (LEAD MOLYBDATE, CHROMATE, SULFATE)
CAS:12656-85-8
RTECS #:QA4660000
Fraction by Wt: <0.4%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUP DAT: INFO & SAFE HNDLG & EXPOS INFO . ANIMAL STUDIES
CLEARLY DEMONSTRATED DOSE-RELATED ADVERSE EFTS ON(ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: THE CNS, HEMATOPOIETIC TISS, BLOOD, KIDNEYS &
LIVER, ASSOC W/ADMIN OF 2-BUTOXYETHANOL (EXTRACTED FROM (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: DHHS (NIOSH) PUBLICATION #90-118) .
RTECS #:9999999ZZ
Ingred Name:EXPLAN OF CARCIN: ANIMAL: NEOPLASTIGENIC, CVS & LUNG EFTS.
MOLYBDATE ORANGE: IARC MONO ON EVALUATION OF CARCIN (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: RISK OF CHEMICALS TO MAN, VOL 49, PG 49, 1990:
GROUP 1.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: KEEP PERS WARM, QUIET & OBTAIN MED ATTN.
NOTE: FOLLOWING ANY FIRST AID, MED ADVICE SHOULD BE (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: OBTAINED, ESPECIALLY IF SYMPTOMS PERSIST.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: PROD CONTAINS LEAD CHROMATES.
DRIED FILM OF THIS PAINT MAY BE HARMFUL/FATAL IF EATEN/CHEWED. CONT
W/BROKEN SKIN/INHAL OF SPRAY MIST/SANDING DUST MAY CAUSE SEV BODILY
HARM. PRLNG/RPTD INHAL & IN GEST, SUCH AS FROM POOR HYGIENE,
HOUSEKEEPING/HNDLG PRACT, CAN RSLT IN LEAD POISONING. EYE: MAY
CAUSE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:ANTIMONY OXIDE: IARC MONO ON EVALUATION
OF CARCIN RISK OF CHEMICALS TO MAN, VOL 47, PG 291, 1989: GROUP 2B.
(ING 16)
Effects of Overexposure:HLTH HAZ: IRRIT, REDNESS, TEARING, BLURRED
VISION & CONJ. SKIN: PRLNG/RPTD CONT MAY CAUSE MOD IRRIT, DEFAT
DERM & ABSORPTION THRU SKIN IN TOX AMTS. INHAL: EXCESS INHAL OF
VAPS MAY CAUSE HDCH, NAUS, DR OW, IRRIT OF MUC MEMB OF NOSE &
THROAT,RESP IRRIT & ALSO ALLERGIC RXN. INGEST: MAY CAUSE NAUS. (SUP
DAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MIN, LIFTING UPPER &
LOWER LIDS OCCAS, OBTAIN MED ATTN. SKIN: WASH CONTAM AREA THORO
W/SOAP & WATER. APPLY MOISTURIZING HAND CREAM. INHAL: REMOVE TO
FRESH AIR. IF B RTHG IS DFCLT, ADMIN OXYGEN ONLY IF TRAINED. IF
BRTHG HAS STOPPED, GIVE ARTF RESP, PREF MOUTH-TO-MOUTH. KEEP PERS
WARM, QUIET & OBTAIN MED ATTN. INGEST: ONLY INDUCE VOMIT AT
INSTRUCTION OF MD.(ING 18)
===================== Fire Fighting Measures =====================
Flash Point:-20F,-29C
Lower Limits:1.9%
Upper Limits:8.5%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROT EQUIP .
WATER MAY BE USED TO COOL CLOSED CONTRS TO PREVENT PRESS BUILD-UP &
POSS EXPLO WHEN EXPOSED TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:SPRAY MIST OR VAPORS FROM CAN PER 400
CUBIC FEET OF AIR MAY REACH LOWER EXPLOSIVE LIMIT AND COULD BE
IGNITED BY A FLAME OR SPARK.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE
AREA. WIPE UP WITH INERT MATERIAL. DO NOT FLUSH INTO DRAINS. REMOVE
RESIDUE WITH A SUITABLE SOLVENT CLEANER IMMEDIATELY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE W/ADEQUATE VENTILATION. WHEN USING
THIS PROD, DO NOT EAT, DRINK/SMOKE. CONTENTS UNDER PRESSURE.
EXPOSURE TO HIGH TEMPERATURES MAY CAUSE BURSTING.
Other Precautions:AVOID STORING NEAR RADIATOR, STOVE, OPEN FLAME/DIRECT
SUNLIGHT. DO NOT INCIN/PUNCTURE CAN. DO NOT SPRAY INTO FLAMES/ANY
INCANDESCENT MATL. DO NOT SMOKE WHILE USING/WHERE SOLV VAPS ARE
PRESENT. DOL STO R CATEGORY: DO NOT STORE AT TEMP >120F.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY NEEDED IF LOCAL EXHAUST IS
SATISFACTORY. IF VENTILATION IS INADEQUATE, USE RESPIRATORY MASK
APPROVED BY NIOSH FOR PROTECTION AGAINST SPRAY MIST.
Ventilation:REQS VARY W/RATE OF PROD USE. SUPPLEMENT VENT TO KEEP BELOW
OSHA & ACGIH PERMISSIBLE LEVELS OF EACH INGREDIENT.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MATLS TO AVOID: LIGHT METALS & THEIR ALLOYS SUCH AS MAGNESIUM. EFTS OF
OVEREXP: CHRONIC: LEAD CHROMATE IS A SUSPECT CANCER HAZ. RISK OF
CANCER DEPENDS ON DURATION & LEVEL OF EXPOS. TOLUENE & LEAD APPE AR
ON NAVY OCCUP CHEM REPRO HAZ LIST. SEEK CONSULT FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZ LIST (ING 13)
================== Physical/Chemical Properties ==================
Vapor Density:HVR/AIR
Spec Gravity:1.20-1.27
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER
Percent Volatiles by Volume:70
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS. ALKALI & ALKALINE EARTH METALS SUCH AS SODIUM,
POTASSIUM & BARIUM. FINE POWDERS OF (SUP DAT)
Stability Condition to Avoid:HEAT, SPARKS AND FIRE.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE, AND
LOCAL LAWS. DO NOT PIERCE OR BURN CAN EVEN AFTER USE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EPHEDRINE SULFATE INJECTION
CAGE:0K706
CAGE:39832
CAGE:0K706
============= Composition/Information on Ingredients =============
Ingred Name:EPHEDRINE SULFATE
CAS:134-72-5
RTECS #:KB2625000
Fraction by Wt: 0.5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM CITRATE
CAS:68-04-2
RTECS #:GE8300000
Fraction by Wt: 0.29%
Other REC Limits:NONE RECOMMENDED
Ingred Name:CITRIC ACID
CAS:77-92-9
RTECS #:GE7350000
Fraction by Wt: 0.05%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM CHLORIDE
CAS:7647-14-5
RTECS #:VZ4725000
Fraction by Wt: 0.69%
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS 600 MG/KG.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE- THIS PRODUCT IS INTENDED FOR
THERAPEUTIC USE ONLY WHEN PRESCRIBED BY A PHYSICIAN. POTENTIAL
ADVERSE REACTIONS FROM PRESCRIBED DOSES AND OVERDOSES ARE
PRESCRIBED IN THE PACKAGE INSERT. OCCUPATIO NAL EXPOSURE HAS NOT
BEEN FULLY INVESTIGATED. CHRONIC- NOT KNOWN
Effects of Overexposure:EYE, SKIN AND RESPIRATORY TRACT IRRITATION
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS MAY BE
MORE SUSCEPTIBLE TO THIS MATERIAL.
======================= First Aid Measures =======================
First Aid:CONSULT PHYSICIAN IF SYMPTOMS PERSIST. EYE/SKIN:FLUSH WITH
WATER FOR 15 MINUTES. HOLD EYELIDS OPEN. INHALATION:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. INGESTION:FLUSH MOUTH OUT WITH
WATER I MMEDIATELY. SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>200F,>93C
Extinguishing Media:WATER FOG, CARBON DIOXIDE, FOAM OR DRY CHEMICAL.
WATER SPRAY MAY BE USED TO KEEP FIRE EXPOSED CONTAINERS COOL.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:MAY EMIT TOXIC FUMES OF NOX, SOX AND
SULFURIC ACID.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. USE ABSORBENT
TOWELS OR BOOMS TO CLEAN-UP SPILL. WIPE SURFACES CLEAN AND WASH
WITH SOAP AND WATER.
Neutralizing Agent:WEAK BASE
======================Handling and Storage ======================
Handling and Storage Precautions:AS A GENERAL RULE, WHEN HANDLING
PHARMACEUTICAL PRODUCTS, AVOID ALL CONTACT AND INHALATION OF DUST,
FUME, MISTS AND/OR VAPORS ASSOCIATED WITH PRODUCT.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WITH SATISFACTORY VENTILATION, RESPIRATORY
PROTECTION NOT USUALLY REQUIRED.
Ventilation:MECHANICAL (GENERAL) ROOM VENTILATION IS USUALLY
SATISFACTORY. USE LOCAL EXHAUST VENTILATION WHEN NECESSARY.
Other Protective Equipment:EYE WASH STATION, DISPOSABLE GARMENTS IF
DIRECT CONTACT IS ANTICIPATED.
Work Hygienic Practices:PRACTICE GOOD HYGIENIC PROCEDURE.
Supplemental Safety and Health
FLASH POINT IS ESTIMATED.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NOT KNOWN
Melt/Freeze Pt:M.P/F.P Text:473F,245C
Vapor Pres:NOT KNOWN
Vapor Density:14.78
Spec Gravity:NOT KNOWN
pH:4.5-7
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR, COLORLESS, ODORLESS SOLUTION
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES
Stability Condition to Avoid:EXPOSURE TO LIGHT MAY CAUSE DECOMPOSITION.
Hazardous Decomposition Products:MAY EMIT TOXIC FUMES OF NOX, SOX AND
SULFURIC ACID.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1819846 EKTAPRINT 2 DEV. REPL. LORR-M
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER, H2O
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 65-70%
Ingred Name:4-(N-ETHYL-N-2-HYDROXYETHYL)-2-METHYLPHENYLENEDIAMINE
SULFATE
CAS:25646-71-4
RTECS #:PB4310000
Fraction by Wt: 25-30%
Ingred Name:POTASSIUM SULFITE
CAS:10117-38-1
RTECS #:WT3530000
Fraction by Wt: 1-5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: IRRITATION, ALLERGIC
REACTION. INHALATION: UPPER RESPIRATORY TRACT IRRITATION.
INGESTION: HARMFUL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN/EYES: IRRITATION, ALLERGIC REACTION.
INHALATION: UPPER RESPIRATORY TRACT IRRITATION. INGESTION: HARMFUL.
Medical Cond Aggravated by Exposure:ALLERGIC REACTION
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH W/WATER FOR AT
LEAST 15 MINS. SKIN: FLUSH W/WATER/WASH W/NON-ALKALINE SKIN
CLEANER. INGESTION: IF CONSCIOUS, RINSE MOUTH/INDUCE VOMITING
IMMEDIATELY BY GIV ING 1 OR 2 GLASSES OF WATER. NEVER GIVEANYTHING
BY MOUTH TO AN UNCONSCIOUSPERSON. OBTAIN MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CO2
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS & FULL
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH MATERIAL TO SEWER W/LARGE AMOUNTS OF
WATER. NEUTRALIZE W/BAKING SODA, SODIUM BICARBONATE.
Neutralizing Agent:BAKING SODA, SODIUM BICARBONATE
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED/AWAY
FROM STRONG ALKALI. AVOID BREATHING VAPOR, CONTACT W/EYES,
SKIN/CLOTHING. WASH THOROUGHLY AFTER HANDLING.
Other Precautions:THE DIRECT INSTANTANEOUS DISCHARGE TO A RECEIVING
BODY OF WATER FOR AN AMOUNT OF THIS CHEMICAL FORMULATION WHICH WILL
RAPIDLY PRODUCE, BY DILUTION, A FINAL CONC. OF 0.09 MG/ OR LESS
ISN'T EXPECTED TO CAUSE AN ADVERSE ENVIRONMENTAL IMPACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED ACID GAS RESPIRATOR SHOULD BE
WORN IF NEEDED.
Ventilation:TYPCIALLY 10 ROOM VOLUMES PER HOUR IS CONSIDERED GOOD
GENERAL VENTILATION
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. WASH/REMOVE
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
AFTER DILUTION W/A LARGE AMOUNT OF WATER, FOLLOWED BY SECONDARY WASTE
TREATMENT, THE CHEMICALS IN THIS FORMULATION AREN'T EXPECTED TO
HAVE ANY ADVERSE ENVIRONMENTAL IMPACT. THIS CHEMICAL FORMULATION I
S A STRONGLY ACIDIC AQUEOUS SOLUTION, &THIS PROPERTY MAY CAUSE
ADVERSE ENVIRONMENTAL EFFECTS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.130
pH:1.17
Solubility in Water:COMPLETE
Appearance and Odor:YELLOW-COLORED SOLUTION; SHARP SULFUR DIOXIDE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, STRONG ALKALI
Stability Condition to Avoid:FIRE OR HEAT
Hazardous Decomposition Products:CO2, CO, OXIDES OF NITROGEN & SULFUR
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE, OR LOCAL LAWS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DOUBLE BASE SMOKELESS PROPELLANT, PC-1
CAGE:0CF24
CAGE:0CF24
CAGE:28284
============= Composition/Information on Ingredients =============
Ingred Name:ING 20: SOURCES & PREVENT BUILD-UP OF STATIC ELECTRIC
CHARGES.
RTECS #:9999999ZZ
Ingred Name:ING 5:MANY TIMES DOSE THAT WOULD BE RECEIVED FOLLOW EXPOS @
TLV, METHEMOGLOBINEMIA & FIBROUS TISSUE FORM IN (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:BILE DUCTS WERE SEEN. TESTICULAR EFTS WERE SEEN IN
RATS DOSED FOR 3 MTHS @ OVER 20,000 TIMES DOSE A WORKER (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:WOULD RECEIVE WORKING @ TLV. IN LETHAL DOSE
DETERMINATIONS IN RATS, RAPID BRTHG, POOR MUSCLE TONE, RAISED (ING
9)
RTECS #:9999999ZZ
Ingred Name:ING 8:HAIR & EXCESS ACTIVITY WERE SEEN.
RTECS #:9999999ZZ
Ingred Name:MED CNDTNS: EXPOS BUT HAS BEEN RPTD FOLLOW PROTRACTED
MEDICINAL OVERDOSAGE OF NITROGLYCERIN. ALCOHOL HAS BEEN (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:RPTD TO INTENSIFY ANY ADVERSE RXN TO NITROGLYCERIN.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH: FACILITIES. METH OF DISPOSING OF MATL IS
TO BURN IN OPEN IN AN ISOLATED LOCATION IN SM, (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:SHALLOW PILES NOT OVER 1 IN DEEP. QTY BURNED @ ANY
ONE TIME SHOULD NOT EXCEED 1 POUND. USE AN IGNIT (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:TRAIN OF SLOW-BURNING COMBUST MATL TO PERMIT RETREAT
TO A SAFE DIST BEFORE POWDER IS IGNITED. STAY (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:UPWIND. DO NOT BREATHE PROD OF COMBUST. ST/LOC DISP
REGS MAY BE MORE STRINGENT THAN FED REGS.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: HIGHLY COMBUST MATL. AVOID EXPOS TO
SUNLIGHT/ARTF ULTRAVIOLET LIGHT. DO NOT KEEP DETERIORATED/ (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:SALVAGED POWDERS IMMED. CHECK OLD POWDERS FOR
DETERIORATION REGULARLY. DESTROY DETERIORATED POWDERS IMMED.
RTECS #:9999999ZZ
Ingred Name:VENT: AIR POLLUTION CONTROL REGULATIONS.
RTECS #:9999999ZZ
Ingred Name:HYGIENE PRACT:CONTAM CLTHG PROMPTLY & CLEAN THORO BEFORE
REUSE. DISCARD CONTAMD LEATHER ARTICLES. DO NOT SMOKE (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19:IN AREAS WHERE POWDER IS STORED/USED. AVOID
FRICTION/ROUGH HNDLG BECAUSE OF FIRE & EXPLO HAZ. ELIM IGNIT (ING
21)
RTECS #:9999999ZZ
Ingred Name:NITROGLYCERIN. TLV: 0.05 PPM OR 0.46 MG/M3, S
CAS:55-63-0
RTECS #:QX2100000
Fraction by Wt: 18-40%
OSHA PEL:S,C, 0.2 MG/M3 STEL
ACGIH TLV:S, 0.46 MG/M3; 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:NITROCELLULOSE
CAS:9004-70-0
RTECS #:QW0970000
Fraction by Wt: 56-79%
Ingred Name:SUPP DATA: DIZZ, ABDOM PAIN, RETROSTERNAL DISCOMFORT,
MUSCLE TWITCHES, HEINZ BODIES (BLACK SPHERES IN RED BLOOD (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:CELLS), METHEMOGLOBINEMIA, DEPRESS, CONFUSN, SKIN
IRRIT, & ALLERGIC SKIN RXN(SENSIT). NOT TERATOGENIC (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:IN RATS/RABBITS. INACTIVE IN DOMINANT LETHAL
MUTAGENICITY TEST. NO EFT ON FERTILITY IN REPROD TESTS. @ (ING 6)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: BRTHG DUST MAY CAUSE SEV HDCH.
ABSORP THRU SKIN MAY CAUSE SEV HDCH. IF SWALLOWED, MAY CAUSE SEV
HDCH & BLOOD PRESS LOWERING. SYMPS OF OVEREXP: INHAL/SKIN/INGEST:
SEV HDCH, NAUS, VOMIT, FATG. CA NCER INFO: NITROGLYCERIN: RATS
DOSED FOR A LIFETIME @ 5,000 TIMES MAX AMT THAT WOULD BE RECEIVED
BY (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: EXPOS @ TLV HAD AN INCR IN LIVER &
TESTICULAR TUMORS. FEMALE RATS DOSED @ THIS SAME HIGH LEVEL FOR A
LIFETIME SHOWED A DECR IN NUMBER OF MAMMARY & PITUITARY TUMORS THAT
USUALLY OCCUR. EFTS R PTD ABOVE ARE ONLY ONES THAT HAVE BEEN RPTD
FOLLOWING WORKPLACE EXPOS. FOLLOW ADDNL EFTS HAVE BEEN RPTD (SUPP
DATA)
Medical Cond Aggravated by Exposure:NITROGLYCERIN-SEV UNTREATED ANEMIA
& GLAUCOMA MAY BE AGGRAVATED BY EXTREME OVEREXP TO NITROGLYCERIN IN
WORKPLACE. AGGRAVATION OF THESE CNDTNS HAS NEVER BEEN RPTD AS A
CONSEQUENCE OF WORKPLACE (ING 10)
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. IF BRTHG HAS STOPPED, GIVE ARTF
RESP. IF BRTHG IS DFCLT, GIVE OXYGEN. CALL PHYS. SKIN: PROMPTLY
WASH W/SOAP/COOL RUNNING WATER. REMOVE CNTAMD CLTHG. WASH LIGHTLY
CONTAMD CL THG W/ALKALINE DETERGENT BEFORE REUSE. DISCARD CONTAMD
LEATHER ARTICLES/HIGHLY CONTAMD CLTHG. INGEST: INDUCE VOMIT. (NEVER
INDUCE VOMIT IN AN UNCON PERSON). CALL PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NOT DETERMINED
Extinguishing Media:DELUGE W/LG QTY OF WATER AS QUICKLY AS POSS BY
AUTOMATIC SPRINKLERS/FIRE HOSE FROM A PROTECTED LOCATION. (SUPP
DATA)
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . EVACUATE AREA.
Unusual Fire/Explosion Hazard:SMOKELESS PROPELLANTS ARE EXTREMELY
FLAMMABLE EXPLOSIVE & READILY IGNITED. PROTECT FROM IMPACT,
FRICTION, HEAT, SPARKS/FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP SPILLS IMMED USING SOFT BRISTLE BRUSH
& CONDUCTIVE RUBBER/PLASTIC SHOVEL. USE CAUTION, MATERIAL IS
SENSITIVE TO INITIATION FROM SOURCES SUCH AS HEAT, FLAME, SHOCK,
FRICTION/SPARKS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:RECOMM STOR: 21C(70F). STORE ONLY IN
DEPT OF TRANSPORTATION APPRVD CONTRS. FOR HNDLG & STOR REQUIREMENTS
SEE 29CFR1910.109.
Other Precautions:ALSO SEE "PROPERTIES & STOR OF SMOKELESS POWDER"
PUBLISHED BY SPORTING ARMS & AMMUNITION MFR'S INSTITUTE,
INCORPORATED (SAAMIN), P.O. BOX 838, BRANDFORD, CT 06405. DO NOT
STORE SMOKELESS POWDER IN SAM E AREA W/SOLV, FLAMM GASES/ (ING 16)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:APPROP NIOSH/MSHA APPRVD RESP PROT REQD WHEN
EXPOS TO AIRBORNE CONTAMINANT IS LIKELY TO EXCEED ACCEPTABLE LIM.
RESP SHOULD BE SELECTED & USED I/A/W OSHA SUBPART I (29CFR1910.134)
& MFR'S RECOMMENDATIO N.
Ventilation:ADEQ VENT SHOULD BE PROVIDED TO KEEP DUST CONC BELOW PEL.
DISCHARGE FROM VENT SYS SHOULD COMPLY W/APPLIC AIR (ING 18)
Other Protective Equipment:FLAME-RETARDANT COVERALLS.
Work Hygienic Practices:DO NOT ALLOW EYE/SKIN CONT. AVOID BRTHG DUST.
WASH THORO AFTER HNDLG, & BEFORE EAT, DRINK/SMOKING. AVOID (ING 19)
Supplemental Safety and Health
EXTING MEDIA: MATLS ARE SELF-OXIDIZING. HAZ DECOMP: MONOXIDE, CARBON
DIOXIDE, & NITROGEN OXIDES. UNDER SOME CNDTNS, METHANE, SM AMTS OF
IRRITATING ALDEHYDES & CARBOXYLIC ACIDS/HYDROGEN CYANIDE MAY BE
FORMED. EFTS OF OVEREXP: FOLLOW MEDICINAL USAGE/OVERUSAGE;
FAINTNESS, SKIN FLUSH, PALPITATION, RAPID HEART BEAT, (ING 3)
================== Physical/Chemical Properties ==================
HCC:E1
Vapor Pres:NEGLIGIBLE
Spec Gravity:1.64
Solubility in Water:NEGLIGIBLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:NEGLIG
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, ALKALIES/AMINES; STRONG SUNLIGHT/ULTRAVIOLET LIGHT.
Stability Condition to Avoid:STORE IN A COOL, DRY PLACE. LONG TERM STOR
@ TEMP >52C(125F) WILL ACCELERATE DECOMP.
Hazardous Decomposition Products:COMBUST PROD VARY DPNDG ON FIRE CNDTNS
& OTHER COMBUST PRESENT IN FIRE. PREDOMINANT PROD WILL BE CARBON
(SUPP DATA)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISP/DESTRUCT OF EXCESS, DMGD/DETERIORATED
EXPLOS SHOULD BE CARRIED OUT UNDER DIRECT SUPERVISON OF A QUALIFIED
PERSON. CALL HERCULES INCORPORATED FOR ASSISTANCE IF NEEDED. FED
HAZ WASTE REGS ALLOW OPE N BURNING/EXPLOS WASTES IN PERMITTED (ING
12)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SUPERMIL GREASE NO. A-72832
CAGE:15958
CAGE:15958
============= Composition/Information on Ingredients =============
Ingred Name:DIESTER OIL
Other REC Limits:NONE SPECIFIED
Ingred Name:LITHIUM SOAP THICKNER
CAS:4485-12-5
RTECS #:WI4370000
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS NOT AVAILABLE
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE/SKIN:MILDLY IRRITATING.
RELEASE DURING HIGH PRESSURE USAGE MAY RESULT IN INJECTION OF OIL
INTO THE SKIN CAUSING LOCAL NECROSIS. INHALATION:NOT EXPECTED TO BE
A RELEVANT ROUTE OF EXPOSURE; H IGH TEMPERATURE VAPORS IRRITATE
RESPIRATORY TRACT. INGESTION:LOW LEVEL OF TOXICITY. CHRONIC:
DERMATITIS.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:MAY CAUSE EYE, SKIN & RESPIRATORY TRACT
IRRITATION. LOCAL NECROSIS IS EVIDENCED BY DELAYED ONSET OF PAIN
AND TISSUE DAMAGE A FEW HOURS FOLLOWING INJECTION.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS MAY BE
AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN IF BREATHING IS
DIFFICULT. GET MEDICAL ATTENTION. EYE: FLUSH WITH WATER FOR 15
MINUTES WHILE HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION. SKIN:
WASH WITH S OAP & WATER/WATERLESS CLEANER. REMOVE CONTAMINATED
CLOTHING. IF IRRITATION PERSISTS, GET MEDICAL ATTENTION. INGESTION:
DO NOT INDUCE VOMITING. IN GENERAL, NO TREATMENT IS REQUIRED. GET
MEDICAL ADVICE.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP UP EXCESS GREASE. CLEAN AREA WITH
APPROPRIATE CLEANER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN
USE. KEEP AWAY FROM OPEN FLAMES & HIGH TEMPERATURES.
Other Precautions:MINIMIZE SKIN CONTACT. WASH WITH SOAP & WATER BEFORE
EATING, DRINKING, SMOKING OR USING TOILET FACILITIES. LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE. PROPERLY DISPOSE OF
CONTAMINATED LEATHER ARTICLES (SHOES) THAT CAN NOT BE
DECONTAMINATED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL(TLV), USE NIOSH/MSHA APPROVED RESPIRATORS AS
PER CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS. RESPIRATORY
PROTECTION NOT ORDINARILY R EQUIRED.
Ventilation:NONE REQUIRED
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
DO NOT GET IN EYES OR ON CLOTHING.
================== Physical/Chemical Properties ==================
HCC:V6
Solubility in Water:NEGLIGIBLE, 0.1%
Appearance and Odor:LAVENDER COLORED, SMOOTHE TEXTURED GREASE.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:A MIXTURE OF AIRBORNE SOLID, LIQUID
PARTICULATES AND GASES (CO) WILL EVOLVE WHEN THIS MATERIAL
UNDERGOES COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN AN APPROPRIATE DISPOSAL FACILITY
IN COMPLIANCE WITH LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:3M CHOKE AND CARBURETOR CLEANER, PART NO:08904
CAGE:52157
CAGE:52157
============= Composition/Information on Ingredients =============
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 10-20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:DIACETONE ALCOHOL (4-HYDROXY-4-METHYL-2-PENTANONE)
CAS:123-42-2
RTECS #:SA9100000
Fraction by Wt: 10-20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:50 PPM
ACGIH TLV:50 PPM; 9394
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 10-20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S, 200 PPM
ACGIH TLV:S,200PPM/250STEL; 94
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 10-20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9394
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 30-40%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM; Z-2
ACGIH TLV:S, 50 PPM; 9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT KNWON
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:IRRIT FROM SPRAY PARTICULATE &
VAPOR.SKIN:IRRIT. INGEST:NOT ANTICIPATED ROUTE DUE TO AEROSOL
NATURE OF PRODUCT.HARMFUL/FATAL,BLINDNESS,SEVERE DIGESTIVE SYS
IRRIT.SOLVENT ASPIRATION INTO LUNG MAY C AUSE LUNG DAMAGE OR BE
FATAL.INHAL:RESPSYS IRRIT & TEMP NERVOUS SYS IMPAIRMENT.
Effects of Overexposure:INHAL:LI-HEAD.TOLUENE:NER SYS
DAMAGE.XYLENE:HEART,LIVER,KIDNEY,BLOOD DAMAGE BASED ON ANIMAL
STUDIES.METHANOL:RESP SYS IRRIT,NER SYS IMPAIRMENT,VISION
EFFECTS,BLINDNESS,BLOOD CHANGES,PARALYSIS,NER SYS & BRAIN
DAMAGE,LUNG,LIVER,KIDNEY & SPLEEN EFFECTS.DIACETONE ALCOHOL:BLOOD
DISORDERS,KIDNEY DAMAGE.HEAD,FTG,DIZZ,WEAK,UNC
Medical Cond Aggravated by Exposure:NONE STATED.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/PLENTY OF WATER FOR @ LEAST 10MINS. CALL
PHYSICIAN. SKIN:WASH WITH SOAP & WATER. INHAL:REMOVE INDIVIDUAL TO
FRESH AIR. CALL DOCTOR. INGEST:DO NOT INDUCE VOMITING. IMMED CALL
PHYSICIAN OR P OISON CONTROL CENTER.
===================== Fire Fighting Measures =====================
Flash Point:-50F,-46C
Lower Limits:1.27
Upper Limits:36.5
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD BE EQUIPPED WITH
SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES INVOLVING
THIS MATERIAL.
Unusual Fire/Explosion Hazard:EXTREMELY FLAMMABLE. TREAT AS PRESSURIZED
CONTAINER. OVERHEATED, CLOSED CONTAINERS ADJACENT TO FIRE COULD
EXPLODE DUE TO INTERNAL PRESSURE BUILDUP.
================== Accidental Release Measures ==================
Spill Release Procedures:IF CANS RUPTURE:EXTINGUISH ALL IGNITION
SOURCES. VENTILATE THE AREA. OBSERVE THE PRECAUATIONS FROM OTHER
SECTIONS. CONTAIN THE SPILL. COVER W/ABSORBENT MATL AS NEEDED.
COLLECT SPILLED MATL. PALCE IN A US DOT-APPROVED METAL CONTAINER &
SEAL.
Neutralizing Agent:NOT STATED.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT/SPARKS/FLAME/OTHER
SOURCES OF IGNITION.VAPORS RELEASED BY PRODUCT CAN BE IGNITED
EASILY & BURN EXPLOSIVELY.AVOID SKIN/EYE CONTACT.
Other Precautions:USE WELL VENTILATED AREAS.USE ONLY AS DIRECTED.DON'T
TAKE INTERNALLY.DON'T STORE @ TEMP >120F.KEEP OUT OF REACH OF
CHILDREN.DON'T BURN CANS IN A HOUSEHOLD INCINERATOR. DON'T PUNCTURE
CANS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE STATED.
Ventilation:USE SUFFICIENT VENTILATION TO MAINTAIN VAPOR & SPRAY
CONCENTRATIONS BELOW RECOMMENDED EXPOSURE LIMITS.
Other Protective Equipment:NONE.
Work Hygienic Practices:AVOID PROLONGED BREATHING VAPORS &
SPRAY(AIRBORNE PRODUCT PARTICLES).
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:COMPRES GAS
Vapor Pres:COMPRE GAS
Vapor Density:3.00
Evaporation Rate & Reference:>5, ETHER=1
Solubility in Water:SLIGHT
Appearance and Odor:CLEAR LIQUID, HEAVY SOLVENT ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NOT APPLICABLE.
Stability Condition to Avoid:DO NOT STORE AT TEMPERATURES ABOVE 120F.
DO NOT PUNCTURE OR INCINERATE.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE, SMOKE
PARTAICLES WHEN SUBJECTED TO EXCESSIVE HEAT OR FLAME.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE ABSORBED & PARTIALLY FULL CANS AFT
MIXING W/FLAMM MATL IN LICENSED HAZ WASTE FACILITY WHICH MUST BE
CAPABLE OF HANDLING AEROSOL CANS.DISPOSE EMPTY CANS IN SANITARY
LANDFILL.DISPOSE IAW APPL ICABLE REGUALTIONS.EPA HAZ WASTE
NO:D001(IGNITABL)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:38122-5 SODIUM PERCHLORATE HYDRATE,99.99%
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM PERCHLORATE HYDRATE
CAS:7601-89-0
RTECS #:SC9800000
Fraction by Wt: 99.99%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 2100 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: HARMFUL. SKIN: HARMFUL
ABSORPTION, IRRITATION. INHALATION: HARMFUL, IRRITATION TO MUCOUS
MEMBRANES & UPPER RESPIRATORY TRACT. EFFECTS TO THYROID & BLOOD.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN/EYES: IRRITATION. IRRITATION TO MUCOUS
MEMBRANES & UPPER RESPIRATORY TRACT.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/PLENTY OF WATER FOR AT LEAST 15
MINS. ASSURE ADEQUATE FLUSHING BY SEPARATING THE EYELIDS W/FINGERS.
SKIN: WASH W/PLENTY OF WATER FOR AT LEAST 15 MIN. REMOVE
CONTAMINATED CLOT HING & SHOES. WASH CONTAMINATED CLOTHING BEFORE
REUSE. INHALATION: REMOVE TO FRESH AIR. IF NECESSARY, GIVE
OXYGEN/CPR. INGESTION: WASH OUT MOUTH W/WATER IF CONSCIOUS. OBTAIN
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, APPROPRIATE FOAM
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING TO PREVENT CONTACT W/SKIN & EYES.
Unusual Fire/Explosion Hazard:CONTACT W/OTHER MATERIAL MAY CAUSE FIRE.
EMITS TOXIC FUMES UNDER FIRE CONDITIONS. FORMS EXPLOSIVE MIXTURES
W/REDUCING AGENTS/MAGNESIUM/FINELY POWDERED METALS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. COVER
W/DRY-LIME/SAND/SODA ASH. PLACE IN COVERED CONTAINERS, USING
NON-SPARKING TOOLS & TRANSPORT OUTDOORS. VENTILATE AREA & WASH
SPILL SITE AFTER MATERIAL PICKUP IS COMPLET E.
Neutralizing Agent:DRY-LIME, SAND, OR SODA ASH
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID INHALATION & CONTACT. KEEP
TIGHTLY CLOSED. DON'T STORE NEAR, NOR ALLOW CONTACT WITH, CLOTHING
& OTHER COMBUSTIBLE MATERIAL.
Other Precautions:STORE IN DRY AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE ONLY IN CHEMICAL FUME HOOD.
Other Protective Equipment:OTHER PROTECTIVE CLOTHING, SAFETY SHOWER,
EYE BATH, RUBBER BOOTS, EYE/FACE PROTECTION
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
THIS MATERIAL IS VERY HYGROSCOPIC.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ORGANIC MATERIALS, STRONG ACIDS, FINELY POWDERED METALS, REDUCING
AGENTS, MAGNESIUM, COMBUSTIBLE MATERIALS
Stability Condition to Avoid:FIRE, MOISTURE
==================== Disposal Considerations ====================
Waste Disposal Methods:BURY IN LANDFILL SITE APPROVED FOR THE DISPOSAL
OF CHEMICAL & HAZARDOUS WASTE. OBSERVE ALL FEDERAL, STATE, & LOCAL
LAWS. UN1502.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DISINFECTANT
CAGE:06335
CAGE:06335
============= Composition/Information on Ingredients =============
Ingred Name:ALKYL DIMETHYL BENZYL AMMONIUM CHLORIDE
CAS:8001-54-5
RTECS #:BO3150000
Fraction by Wt: 40%
Ingred Name:UREA
CAS:57-13-6
RTECS #:YR6250000
Fraction by Wt: 60%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE
Explanation of Carcinogenicity:THIS PRODUCT IS NOT CONSIDERED TO BE
CARCINOGEN
Effects of Overexposure:EYE: PAINFUL AND IRRITATING
SKIN: PROLONGE/REPEATED CONTACT
WITH SKIN CAUSES IRRITATION
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:EYE: FLUSH IMMEDIATELY WITH PLENTY OF WATER FOR 15 MINUTES
SKIN: WASH OFF SKIN WITH WATER
INGST: CONSULT A PHYSICIAN
IMMEDIATELY
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:KN
Extinguishing Media:NON FLAMMABLE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP POWDER, RINSE WITH WATER
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN DRY PLACE BETWEEN 50-120F
Other Precautions:AVOID CONTACT WITH ALUMINUM, BRASS, COPPER, BLACK
IRON
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:NONE
Other Protective Equipment:NONE
Work Hygienic Practices:USE PRODUCT ACCORDING TO INSTRUCTION LABELS
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:250F
Melt/Freeze Pt:M.P/F.P Text:250F
Vapor Pres:NONE
Vapor Density:NONE
Spec Gravity:0.6
Evaporation Rate & Reference:NONE
Solubility in Water:COMPLETE
Appearance and Odor:BUFF WHITE POWDER SLIGHT AMMONIA ODOR
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ANIONIC SOAPS (DEACTIVATES DISINFECTANTS) STRONG OXIDIZERS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:QA-40 IS DEGRADABLE IN ALL SEWAGE SYSTEMS AT 200
PPM, QA-40 IS APPROVED FOR SANITIZING FOOD CONTACTITEMS WITH NO
POTABLE WATER RINSE.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:40826 COAGULASE PLASMA, RABBIT W/EDTA, LYOPHILIZED
Preparer's Name:DALE M OREM
CAGE:06531
CAGE:05545
CAGE:06531
============= Composition/Information on Ingredients =============
Ingred Name:POWDER, LYOPHILIZED
Ingred Name:ACETIC ACID (ETHYLENEDIAMINETETRAACETIC ACID), EDTA
CAS:60-00-4
RTECS #:AH4025000
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
===================== Fire Fighting Measures =====================
Extinguishing Media:WATERSPRAY
Unusual Fire/Explosion Hazard:ANY ORGANIC POWDER CAN BE POTENTIALLY
EXPLOSIVE IF DISBURSED IN AIR IN CERTAIN CONCENTRATIONS.
CONCENTRATIONS HAVE NOT BEEN DETERMINED.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SOLUTIONS W/PAPER TOWELS. POWDERED
MATERIAL SHOULD BE SWEPT UP & DISPOSED OF W/NORMAL LAB TRASH.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER NORMAL PRODUCT USAGE
Ventilation:GENERAL & LOCAL TO MEET TLV REQUIREMENT
Other Protective Equipment:NOT REQUIRED UNDER NORMAL PRODUCT USAGE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT TAN YELLOW LYOPHILIZED POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:MATERIAL MAY BE DISPOSED OF W/NORMAL LAB TRASH.
FOLLOW ALL CURRENT FEDERAL, STATE & LOCAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:RTV8112
Kit Part:Y
Preparer's Name:DA POLSINELLI
CAGE:01139
CAGE:01139
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLORTHOSILICATE
CAS:110990-60-2
Fraction by Wt: 1-5%
Other REC Limits:NONE SPECIFIED
Ingred Name:CALCIUM CARBONATE
CAS:471-34-1
RTECS #:FF9335000
Fraction by Wt: 10-30%
Other REC Limits:NONE SPECIFIED
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:DIMETHYL POLYSILOXANE SILANOL/ST
CAS:70131-67-8
Fraction by Wt: 60-80%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ACUTE ORAL LD50: 1000 MG/KG RAT
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: HARMFUL IF SWLLOWED. SKIN:
SKIN IRRITATION IS NOT EXPECTED. INHALATION: MAY CAUSE MILD
RESPIRATORY IRRITATION. EYES: MAY IRRITATE. CHRONIC EFFECTS OF
OVEREXPOSURE: RESPIRATORY AILMENTS. LIVER AND KIDNEY DAMAGE.
Effects of Overexposure:IRRITATION AS NOTED IN THE HEALTH HAZARDS
SECTION.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INGESTION: DO NOT INDUCE VOMITING. SLOWLY DILUTE WITH 1-2
GLASSES OF WATER OR MILK AND SEEK MEDICAL ATTENTION. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. SKIN: WASH WITH SOAP
AND WATER. INHALATION: NONE KNOWN. EYES: IN CASE OF CONTACT,
IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES AND
GET MEDICAL ATTENTION IF IRRITATION PERSISTS.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:570F,299C
Extinguishing Media:ALL STANDARD FIREFIGHTING MEDIA.
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE, SCRAPE OR SOAK UP IN AN INERT MATERIAL
AND PUT IN A CONTAINER FOR DISPOSAL. WASH WALKING SURFACES WITH
DETERGENT AND WATER TO REDUCE SLIPPING HAZARD. WEAR PROPER
PROTECTIVE IQUIPMENT AS SPECIFIE D IN THE PROTECTIVE EQUIPMENT
SECTION.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH SKIN AND EYES. USE
ONLY IN A WELL-VENTILATED AREA.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE ONLY IN A WELL-VENTILATED AREA.
Ventilation:LOCAL EXHAUST VENTILATION.
Other Protective Equipment:EYEWASH STATION.
Work Hygienic Practices:WASH HANDS AFTER HANDLING THIS MATERIAL.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.2
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE LIQUID WITH A SLIGHT ODOR.
Percent Volatiles by Volume:2
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
Hazardous Decomposition Products:CARBON MONOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:STRATUS DUSTER, 1001,1002, 1003, 1004, 1010, 1011, AERSOSOL
Preparer's Name:B. RIFFEL
CAGE:TO864
CAGE:TO864
============= Composition/Information on Ingredients =============
Ingred Name:1,1,1,2-TETRAFLUOROETHANE
CAS:811-97-2
= Wt:100.
Other REC Limits:1000PPM (SUPPLIER)
OSHA PEL:NIF
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAJOR POTENTIAL ROUTE OF
EXPOSURE. MINIMAL EFFECTS OBSERVED BELOW 1000 PPM. DIZZINESS,
DROWSINESS & THROAT IRRITATION POSSIBLE AT LEVELS ABOVE 1000 PPM.
UNCONSCIOUSNESS & DEATH AT LEVELS A BOVE 10,000 PPM. BLOOD PRESSURE
DEPRESSION, CARDIAC SENSITIZATION & VENTRICULAR ARRHYTHMIA CAN
RESULT FROM EXPOSURE TO NEAR-ANESTHETIC LEVELS. EYES: LIQUID CAN
CAUSE SLIGHT, TEMPORARY IRRITATION WITH SLIGHT TEMPORARY CORNEAL
INJURY. VAPORS CAN IRRITATE EYES. SKIN: PROLONGED OR REPEATED
CONTACT WITH LIQUID CAN CAUSE FREEZING OF SKIN TISSUES, DEFATTING,
AND DERMATITIS. INGESTION: SINGLE DOSE TOXICIT Y IS (SIGNS &
SYMPTOMS OF OVEREXPOSURE)
Effects of Overexposure:HEALTH HAZARDS ACUTE AND CHRONIC (CONT): LOW TO
MODERATE. IF VOMITING OCCURS, LIQUID CAN BE ASPIRATED INTO LUNGS,
WHICH CAN CAUSE CHEMICAL PNEUMONIA AND SYSTEMIC EFFECTS. HUMAN
PSYCHOTROPIC, GASTROINT ESTINAL, AND CENTRAL NERVOUS SYSTEM EFFECTS
POSSIBLE.
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE TO FRESH AIR IN CASE OF ACCIDENTAL
INHALATION OF VAPORS. IF VICTIM HAS STOPPED BREATHING, GIVE
ARTIFICIAL RESPIRATION. CALL FOR PROMPT MEDICAL ATTENTION. EYES:
FLUSH WITH LARGE AMOUNT S OF WATER FOR 15 MIN OR UNTIL IRRITATION
SUBSIDES. IF IRRITATION PERSISTS, GET MEDICAL ATTN. SKIN: REMOVE
CONTAMINATED CLOTHING (INCLUDING SHOES) AND WASH BEFORE REUSE.
FLUSH WITH LARGE AMOUNTS OF WA TER. USE SOAP IF AVAILABLE. IF
IRRITATION PERSISTS, SEEK MEDICAL ATTN. INGESTION: DO NOT INDUCE
VOMITING UNLESS DIRECTED BY A PHYSICIAN. IF CONSCIOUS AND ALERT,
GIVE TWO GLASSES OF WATER. SEEK MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE-TCC METHOD
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:WATER, FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR SELF-CONTAINED,
POSITIVE-PRESSURE BREATHING APPARATUS [NIOSH-APPROVED; FP N] AND
AVOID SKIN CONTACT. HAZARDOUS COMBUSTION PRODUCTS: SMOKE, FUMES AND
OXIDES OF CARBON.
Unusual Fire/Explosion Hazard:GENERAL HAZARD: AEROSOL CANS MAY ERUPT
WITH FORCE AT TEMPERATURES ABOVE 120F.
================== Accidental Release Measures ==================
Spill Release Procedures:LAND SPILL: EVACUATE AREA. VENTILATE AREA WELL
AND AVOID BREATHING VAPORS. VAPOR CONCENTRATION WILL BE HIGHEST
ALONG FLOOR AND IN LOW-LYING AREAS. PICK UP LIQUID ON SUITABLE
ABSORBENT AND STORE IN SEA LED CONTAINERS.WATER SPILL: N/P.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE: KEEP CONTAINER CLOSED WHEN
NOT IN USE. STORE IN COOL, WELL-VENTILATED PLACE OUT OF DIRECT
SUNLIGHT & AWAY FROM INCOMPATIBLE MATERIALS. FOLLOW ALL MSD SHEET
AND LABEL WARNINGS EVEN AFTER CONTA INER IS EMPTIED. STORAGE
TEMPERATURE: AMBIENT. STORAGE PRESSURE: ATMOSPHERIC.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF CONCENTRATIONS ARE OVER EXPOSURE LIMIT AND
ARE KNOWN, AIR PURIFYING RESPIRATOR WITH ORGANIC VAPOR CARTRIDGES
MAY BE ACCEPTABLE. REFER TO CARTRIDGES FOR ACCEPTABLE LEVELS. IF
CONCENTRATIONS ARE OVER EXPOSURE LIMIT AND ARE UNKNOWN, USE A
SUPPLIED AIR RESPIRATOR (NIOSH-APPROVED - ).
Ventilation:LOCAL EXHAUST VENTILATION ACCEPTABLE.
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA .
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:=-32.6C, -27.F
B.P. Text:-16C / 27F
Melt/Freeze Pt:M.P/F.P Text:NIF
Vapor Density:3.0(AIR=1)
pH:7-8
Evaporation Rate & Reference:(H2O=1): >1
Solubility in Water:0
Appearance and Odor:CLEAR WATER-WHITE LIQUID WITH LOW ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH OPEN FLAME, HEAT, REACTIVE ALKALI METALS, STRONG
ACIDS AND BASES.
Stability Condition to Avoid:GENERAL: STABLE.
Hazardous Decomposition Products:HYDROGEN FLUORIDE, CARBON DIOXIDE AND
CARBON MONOXIDE.
=================== Toxicological Information===================
Toxicological Information:RESULTS OF COMPONENT TOXICITY TEST PERFORMED:
INFORMATION NOT AVAILABLE.HUMAN EXPERIENCE: INFORMATION NOT
AVAILABLE.
===================== Ecological Information =====================
Ecological:INFORMATION NOT AVAILABLE.OTHER INFORMATION (CONT):
ABBREVIATIONS USED IN THIS DOCUMENT: NE-NOT ESTABLISHED. NA-NOT
APPLICABLE. NIF-NO INFORMATION FOUND. REVISION DATES, SECTIONS,
REVISED BY: 10 AU G 95; CREATED; B. RIFFEL. 02 JUL 96; ADDED PART
NUMBERS IN SECTION 1; B. RIFFEL. 04 APR 98; ADDED PART NO.;
REVIEWED; B. RIFFEL. REFERENCES: CODE OF FEDERAL REGULATIONS (CFR).
SIGMA-ALDRICH LIBRARY OF REGULATORY & SAFETY DATA. CHEMICAL GUIDE
& OSHA HAZARD COMMUNICATION STANDARD. VARIOUS FEDERAL, STATE &
LOCAL REGULATIONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:RCRA 40 CFR 261 CLASSIFICATION: N/P. FEDERAL,
STATE AND LOCAL LAWS GOVERNING DISPOSAL OF MATERIALS CAN DIFFER.
ENSURE PROPER DISPOSAL COMPLIANCE WITH PROPER AUTHORITIES BEFORE
DISPOSAL.
=================== MSDS Transport Information ===================
Transport Information:U.S. D.O.T. INFORMATION: PROPER SHIPPING NAME:
CONSUMER COMMODITY ORM-D. HAZARD CLASS, PACKAGING GROUP, UN NUMBER:
N/A. LIMITATIONS: MUST MAKE SURE ALL DIAMOND LABELS, PROPER
SHIPPING NAMES, UN NUMBER S & DOT-E-10232 ARE COVERED UP. MUST
PLACE CONSUMER COMMODITY ORM-D LABEL ON TOP OF BOX. IATA: PROPER
SHIPPING NAME: CONSUMER COMMODITY. HAZARD CLASS: 9. PACKING GROUP:
N/A. UN NUMBER: ID8000. LIMITAT IONS: MUST SEND CY OF OF
DOT-E-10232 CARGO AIRCRAFT ONLY. DOMESTIC SHIPMENTS ONLY. WHEN
SHIPPING INTERNATIONAL CONTACT TECH SPRAY SHIPPING DEPARTMENT.
(OTHER INFO)
===================== Regulatory Information =====================
SARA Title III Information:CERCLA/SUPERFUND, 40 CFR 117, 302: NONE OF
THE CHEMICALS ARE SUPERFUND HAZARDS. SARA ACT OF 1986, TITLE III,
SECTIONS 302, 311, 312, 313: SEC 302: EXTREMELY HAZARDOUS
SUBSTANCES (40 CFR 355): NONE OF THE CHEMICALS ARE SECTION 302
HAZARDS. SECTION 311/312-MSDS REQUIREMENTS (40 CFR 370): BY OUR
HAZARD EVALUATION, THIS PRODUCT IS HAZARDOUS. IT SHOULD BE REPORTED
UNDER THE FOLLOWING EPA HAZARD: IMMEDI ATE (ACUTE) HEALTH HAZARD.
SECTION 313-LIST OF TOXIC CHEMICALS (40 CFR 372) PRODUCT CONTAINS
FOLLOWING CHEMICALS (AT LEVELS OF 1% OR GREATER) WHICH ARE FOUND ON
313 LIST OF TOXIC CHEMICALS: NONE OF CH EMICALS ARE 313 TOXIC
CHEMICALS.
Federal Regulatory Information:MSDS COMPLIES WITH OSHA'S HAZARD
COMMUNICATION RULE 29 CFR 1910.1200. TOXIC SUBSTANCES CONTROL ACT
(TSCA): ALL SUBSTANCES ARE TSCA LISTED. RESOURCE CONSERVATION AND
RECOVERY ACT (RCRA 40 CFR 261), S UBPART C&D: REFER TO
TOXICOLOGICAL SECTION FOR RCRA CLASSIFICATION. FEDERAL WATER
POLLUTION CONTOL ACT, CLEAN WATER ACT, 40 CFR 401.15 (FORMERLY
SECTION 307), 40 CFR 116 (FORMERLY SECTION 311), CLEAN AIR ACT: NO
INFORMATION. INTERNATIONAL REGULATIONS: CANADA WHIMS: NIF. EUROPE
EINECS NUMBERS: TETRA FLUOROETHANE; 811-97-2.
State Regulatory Information:CALIFORNIA PROPOSITION 65: PRODUCT
CONTAINS FOLLOWING INGREDIENTS WHICH APPEAR ON CALIFORNIA
PROPOSITION 65 LIST: NONE OF CHEMICALS ARE ON PROPOSITION 65 LIST.
======================= Other Information =======================
| 1 | gloves_mandatory |
=======================================================
Product ID: ULTIMATE II GRAFFITI REMOVER LIQUID
Cage: DO814
Box: 1547
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 26290
Cage: DO814
Box: 1547
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: EXPOSURE MAY CAUSE EYE, SKIN & RESPIRATORY
TRACT IRRITATION. INGESTION MAY CAUSE GI TRACT IRRITATION. CHRONIC: NONE
SPECIFIED BY MANUFACTURER.
Explanation Of Carcinogenicity: NO INGREDIENT OF A CONCENTRATION OF 0.1% OR
GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Signs And Symptions Of Overexposure: EYES-IRRITATION. SKIN-IRRITATION.
INHALED-RESPIRATORY TRACT IRRITATION. INGESTED-GI TRACT IRRITATION, NAUSEA,
VOMITING, DIARRHEA.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES-FLUSH WITH LOTS OF WATER FOR 10 MINUTES. CONSULT DOCTOR IF
IRRITATION PERSISTS. SKIN-FLUSH WITH PLENTY OF WATER. INGESTED-DO NOT INDUCE
VOMITING. IF CONSCIOUS, DRINK WATER & CONSULT A PHYSICIAN.
INHALED-REMOVE FROM EXPOSURE.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: ABSORB MATERIAL AND FLUSH AREA WITH WATER. KEEP OPEN
FLAMES OR SPARKS AWAY.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
ENVIRONMENTAL REGULATIONS.
Handling And Storage Precautions: USE POLYETHYLENE CONTAINERS ONLY. STORE IN A
COOL, DRY PLACE.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: 175F,79C
Autoignition Temp Text: 459F
Lower Limits: 0.7
Upper Limits: 6.1
Extinguishing Media: NONE SPECIFIED BY MANUFACTURER. DLA-: USE MEDIA
APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures: NONE SPECIFIED BY MFR. DLA-: WEAR SELF-CONTAINED
BREATHING APPARATUS AND FULL FIRE FIGHTER'S PROTECTIVE GEAR. USE WATER TO
COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard: NONE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE NORMALLY REQUIRED. IF ENGINEERING CONTROLS FAIL OR
NON-ROUTINE USE OR AN EMERGENCY OCCURS; WEAR AN MSHA/NIOSH APPROVED
RESPIRATOR WITH ORGANIC VAPOR CARTRIDGE OR AN AIR-SUPPLIED RESPIRATOR OR SCB
A, AS REQUIRED. USE IAW 29 CFR 1910.134.
Ventilation: DLA-: USE ADEQUATE MECHANICAL VENTILATION OR LOCAL EXHAUST TO
MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment: NONE SPECIFIED BY MANUFACTURER. DLA-: EYE WASH
STATION & SAFETY SHOWER.
Work Hygienic Practices: WASH HANDS AFTER HANDLING AND BEFORE EATING, DRINKING,
OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health: MSDS PRESENTED BY CAGE 26290 FOR CONTRACT
NUMBER MDA414-96-PE714.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: V4
B.P. Text: 351F,177C
M.P/F.P Text: UNKNOWN
Decomp Text: UNKNOWN
Vapor Pres: UNKNOWN
Vapor Density: 4.7
Spec Gravity: UNKNOWN
Viscosity: UNKNOWN
Evaporation Rate & Reference: VERY SLOW
Solubility in Water: COMPLETE
Appearance and Odor: CLEAR, THICK LIQUID; MILD ODOR.
Corrosion Rate: UNKNOWN
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: STRONG OXIDIZING AGENTS, REDUCING AGENTS.
Hazardous Decomposition Products: NONE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: CANNOT OCCUR.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 5007
Product ID: ULTIMATE II GRAFFITI REMOVER LIQUID
Review Date: 10/10/1996
Net Unit Weight: 2.1 LBS EST
Multiple KIT Number: 0
Review IND: Y
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: ULTIMATE II GRAFFITI REMOVER LIQUID
Cage: DO814
Assigned IND: Y
Company Name: ULTIMATE SPECIALTY PRODUCTS
Street: UNKNOWN
PO Box: 1547
Zipcode: 75001
Label Required IND: Y
Date Of Label Review: 10/10/1996
Status Code: C
Label Date: 10/10/1996
Year Procured: 1996
Origination Code: F
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE! EXPOSURE MAY CAUSE EYE, SKIN &
RESPIRATORY TRACT IRRITATION. INGESTION MAY CAUSE GI TRACT IRRITATION. TARGET
ORGANS: SKIN, EYES, LUNGS, GI TRACT. IN CASE OF SPILL: ABSORB MATERIAL AND
FLU SH AREA WITH WATER. KEEP OPEN FLAMES ORSPARKS AWAY. FIRST AID: EYES-FLUSH
WITH LOTS OF WATER FOR 10 MINUTES. CONSULT DOCTOR IF IRRITATION PERSISTS.
SKIN-FLUSH WITH PLENTY OF WATER. INGESTED-DO NOT IND UCE VOMITING. IF
CONSCIOUS, DRINK WATER & CONSULT A PHYSICIAN. INHALED-REMOVE FROM
EXPOSURE.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PBD
CAGE:9Z504
CAGE:9Z504
============= Composition/Information on Ingredients =============
Ingred Name:PBD; (2-[1,1'-BIPHENYL]-4-YL-5-PHENYL-1,3,4-OXADIAZOLE)
CAS:852-38-0
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NOT ESTABLISHED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. TREAT SYMPTOMATICALLY. IF
SYMPTOMS ARE PRESENT GET MEDICAL ATTENTION. SKIN: IMMEDIATELY FLUSH
SKIN WITH PLENTY OF WATER. EYES: IMMEDIATELY FLUSH EYES WITH PLENTY
OF WA TER FOR AT LEAST 15 MINUTES AND GET MEDICAL ATTENTION IF
SYMPTOMS ARE PRESENT. INGESTION: DRINK 1-2 GLASSES OF WATER OR
MILK. CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP MATERIAL AND PACKAGE FOR SAFE FEED TO
AN INCINERATOR.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM CONTACT WITH OXIDIZING
MATERIALS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH/MSHA APPROVED DUST RESPIRATOR SHOULD BE
WORN, IF NEEDED.
Ventilation:GOOD GENERAL ROOM VENTILATION SHOULD BE USED. LOCAL EXHAUST
MAY BE NEEDED.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
% VOLAT: NEGLIGIBLE (BY WEIGHT).
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:>333F,>167C
Vapor Pres:NEGLIGIBLE
Evaporation Rate & Reference:NEGLIG(N-BUTYL ACETATE=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE CRYSTALLINE POWDER; NO ODOR.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:COMBUSTION WILL PRODUCE CARBON DIOXIDE
& PROBABLY CARBON MONOXIDE. OXIDES OF NITROGEN MAY ALSO BE PRESENT.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE BY INCINERATION OR CONTRACT WITH
LICENSED CHEMICAL WASTE DISPOSAL AGENCY. DISCHARGE, TREATMENT OR
DISPOSAL ARE SUBJECT TO FEDERAL, STATE AND LOCAL LAWS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:KA1E1 CP125-375-005 A2A1 CB300 PART B
Kit Part:Y
CAGE:MO939
CAGE:MO939
============= Composition/Information on Ingredients =============
Ingred Name:TRADE SECRET
Ingred Name:TRADE SECRET
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PERMISSIBLE EXPOSURE LEVEL: NO OSHA
LIMITS HAVE BEEN ESTABLISHED FOR THIS PRODUCT. INHALATION: SLIGHTLY
TOXIC. CAN CAUSE IRRITATION OF RESPIRATORY TRACT. OVEREXPOSURE TO
VAPOR OR FUMES MAY CAUSE DELAY ED LUNG DAMAGE AND CHEMICAL
PNEUMONIA. EYE CONTACT: CAN BE CORROSIVE TO EYE TISSUE LEADING TO
PERMANENT INJURY AND EVEN BLINDNESS. INGESTION: SLIGHTLY TOXIC.
INGESTION MAY CAUSE FATIGUE, MUSCULAR WEAK NESS, LABORED BREATHING
AND IRRITATION OF GASTRO-INTESTINAL TRACT. SKIN: MAY CAUSE SEVERE
SKIN IRRITATION. CORROSIVE ON PROLONGED CONTACT. MAYBE A
SENSITIZER. SKIN ABSORPTION: SLIGHTLY TOXIC.
Effects of Overexposure:ACUTE OVEREXPOSURE: SEVERE BURNS TO SKIN, EYES,
RESPIRATORY AND GASTROINTESTINAL TRACT. CHRONIC OVEREXPOSURE:
DERMATITIS, DELAYED LUNG INJURY, CHEMICAL PNEUMONIA. NOTE TO
PHYSICIAN: GASTRIC LAVAGE MA Y BE CONSIDERED DEPENDING ON DEGREE OF
MUCOSAL DAMAGE. TREATMENT FOR SHOCK, RESPIRATORY DEPRESSION AND
CONVULSIONS MAY BE NECESSARY.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE PERSON TO FRESH AIR. GIVE OXYGEN IF
BREATHING IS DIFFICULT. GET IMMED MED ATTN. EYE: FLUSH THOROUGHLY
W/WATER FOR AT LEAST 15 MINS WHILE LIFTING UPPER AND LOWER LIDS.
GET IMMED MED ATTN. INGEST: DO NOT INDUCE VOMIT. GIVE LARGE
AMOUNTS OF WATER/MILK IF AVAIL & TRANSPORT TO MEDICAL FACILITY.
SKIN: IMMED REMOVE CONTAMINATED CLOTHES/SHOES. WIPE EXCESS FROM
SKIN & FLUSH W/PLENTY OF W ATER FOR AT LEAST 15 MINS. USE SOAP IF
AVAIL OR FOLLOW BY WASHING W/SOAP & WATER. DO NOT REUSE CLOTHING
UNTIL THOROUGHLY CLEANED. GET MED ATTN. CONTAM LEATHER ARTICLES,
INCL SHOES, CANNOT BE DECONTAM & SHOULD BE DESTROYED TO PREVENT
REUSE.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:=132.2C, 270.F
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, FOAM AND CARBON DIOXIDE.
Fire Fighting Procedures:DO NOT ENTER CONFINED FIRE SPACE WITHOUT FULL
RUBBER BOOTS), INCLUDING A POSITIVE PRESSURE NIOSH APPROVED
SELF-CONTAINED BREATHING APPARAT US. COOL FIRE EXPOSED CONTAINERS
WITH WATER.
Unusual Fire/Explosion Hazard:FIRE EXPOSED CONTAINERS MAY BUILD
PRESSURE AND BURST. FLAMMABILITY CLASS: N/A.
================== Accidental Release Measures ==================
Spill Release Procedures:IN CASE OF SPILLS: SHUT OFF ALL IGNITION
SOURCES AND DIKE SPILL TO CONTAIN AND PREVENT ENTRY INTO SEWER OR
WATER SOURCES. ABSORB SPILLED MATERIAL AND PLACE IN CLOSED
CONTAINER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP AWAY
FROM OPEN FLAMES AND HIGH TEMPERATURES.
Other Precautions:DO NOT REUSE CONTAMINATED CLOTHING UNTIL THOROUGHLY
CLEANED. CONTAMINATED LEATHER ARTICLES, INCLUDING SHOES, CANNOT BE
DECONTAMINATED AND SHOULD BE DESTROYED TO PREVENT REUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN THE ABSENCE OF PROPER ENVIRONMENTAL CONTROL
OR VENTILATION, WEAR A RESPIRATOR APPROVED BY NIOSH WHENEVER
EXPOSED TO FUMES OR VAPORS. COMPLY WITH OSHA 1910.134 (CFR). NIOSH
APPROVED SELF-CONTAINED B REATHING APPARATUS IN HIGH
CONCENTRATIONS.
Ventilation:LOCAL EXHAUST IS RECOMMENDED.
FACESHIELD . (SUP DATA)
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING TO MINIMIZE
EXPOSURE; CHEMICAL SPLASH APRON, FULL FACE SHIELD. EYE WASH STATION
AND DELUGE SAFETY SHOWER MEETING ANSI DESIGN CRITERIA SHOULD BE
AVAILABLE FOR EMERGENCY USE.
Supplemental Safety and Health
PHYSICAL/CHEMICAL DATA: VAPOR DENSITY: HEAVIER THAN AIR. LIQUID
DENSITY: HEAVIER THAN WATER. WGT %: 0.8. FLAMMABILITY CLASS: N/A.
================== Physical/Chemical Properties ==================
Vapor Density:SUP DATA
VOC Grams/Liter:9.4
Evaporation Rate & Reference:UNAVAILABLE.
Appearance and Odor:LIQUID.
Percent Volatiles by Volume:0.9
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SEE CONDITIONS TO AVOID.
Stability Condition to Avoid:OXIDIZING AGENTS, STRONG MINERAL ACIDS,
STRONG LEWIS ACIDS, ACIDS AND HALOGENATED ORGANIC COMPOUNDS.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
HYDROGEN SULFIDE, OXIDES OF SULFUR, NITROGEN OXIDES AND AMMONIA.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED INCINERATION. HANDLE IN COMPLIANCE
WITH LOCAL, STATE AND FEDERAL ENVIRONMENTAL PROTECTION REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:SHIPPING INFORMATION: PLASTIC LIQUID NOS NMF#
156240 LIQUID CHEMICALS (NOT REGULATED BY DOT). "EMERGENCY CONTACT"
CHEMTREC (800) 424-9300 TRADE NAME: EPOWELD 8173 PART B. "EMERGENCY
CONTACT" CHEM-TEL (800) 255-3924 TRADE NAME: DOUBLE/BUBBLE
RED/WHITE (04001) PART B. DOT SHIPPING INFORMATION (DOMESTIC
GROUND): THIS PRODUCT IS NOT REGULATED BY THE U.S. DOT NMF#156240.
THIS PRODUCT (OR COMPONENTS, I F MIXTURE) IS NOT LISTED IN IARC
MONOGRAPHS, THE NTP FOURTH ANNUAL REPORT OR THE CURRENT ACGIH TLVS
AS A CARCINOGEN. IT IS NOT REGULATED BY OSHA AS A CARCINOGEN.
===================== Regulatory Information =====================
SARA Title III Information:THIS PRODUCT CONTAINS THE FOLLOWING TOXIC
CHEMICALS SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF
THE EMERGENCY PLANNING AND COMMUNITY RIGHT TO KNOW ACT OF 1986 AND
OF 40 CFR 372: NONE.
Federal Regulatory Information:ALL INGREDIENTS IN THIS PRODUCT ARE
LISTED IN THE T.S.C.A. INVENTORY.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1B15H
CAGE:HUMIS
CAGE:HUMIS
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 30-39%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 18-23%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 8-12%
Other REC Limits:NONE SPECIFIED
OSHA PEL:350 PPM/450 STEL
ACGIH TLV:350 PPM/450STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 15-20%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9192
Ingred Name:BUTANE
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: 15-20%
Other REC Limits:NONE SPECIFIED
OSHA PEL:800 PPM
ACGIH TLV:800 PPM; 9192
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE GIVEN
Effects of Overexposure:SKIN;IRRITATION,REDNESS,BLURRED
VISION,EDEMA,DIZZINESS,FATIGUE,NAUSEA, VOMITING,UNCONSCIOUNESS
NOSEBLEEDS.
Medical Cond Aggravated by Exposure:NONE GIVEN
======================= First Aid Measures =======================
First Aid:CONSULT A PHYSICIAN IMMEDIATELY,WASH SKIN WITH SOAP AND
WATER,FLUSH EYES WITH WATER,INGESTION; GIVE TWO GLASSES OF WATER IF
CONSCIOUNESS.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:20.0F,-6.7C
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:FOAM,CARBON DIOXIDE, DRY CHEMICALS.
Fire Fighting Procedures:FIGHT AS A FLAMMABLE LIQUID FIRE,WEAR SCBA.
Unusual Fire/Explosion Hazard:VAPOR IS FLAMMABLE AND HEAVIER THAN AIR
AND MAY TRAVEL TO SOURCES OF IGNITION AND IGNITE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH INERT MATERIAL,SAND,EARTH
EVRMICULITE ETC. LARGE SPILLS MAY BE SCOOPED UP WITH NONSPARKING
TOOLS,REMOVE SOURCES OF IGNITION. VENTIATE AREA.
Neutralizing Agent:NA
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWY FROM HEAT,SPARKS AND OPEN
FLAMES. STORE AT AMBIENT TEMPERATURE.
Other Precautions:KEEP CONTAINER CLOSED, USE ADEQUATE VENTILATION,
AVOID CONTACT WITH EYES,SKIN AND CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ORGANIC TYPE IF TVLS ARE EXCEEDED
Ventilation:EXPLOSION PROOF
Other Protective Equipment:TO PREVENT CONTACT WITH WORKERS.
Work Hygienic Practices:PRUDENT
Supplemental Safety and Health
NA
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:NA
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:NA
Evaporation Rate & Reference:NA
Solubility in Water:NEGIBLE
Appearance and Odor:WATER CLEAR,LOW VISCOSITY LIQUID,AROMATIC ODOR
Percent Volatiles by Volume:NA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NA
Hazardous Decomposition Products:CARBON MONOXIDE,CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:STRICT COMPLIANCE WITH LOCAL STATE AND FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:OMEGA 2513A SN 313-3
Preparer's Name:PAUL ZALANTIS, PRESIDENT
CAGE:0B5U9
CAGE:0B5U9
============= Composition/Information on Ingredients =============
Ingred Name:METHYLENE CHLORIDE(SARA III)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 86%
Other REC Limits:NONE SPECIFIED
OSHA PEL:500 PPM/C,1000; Z2
ACGIH TLV:50 PPM, A2; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 9%
Other REC Limits:NONE SPECIFIED
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:ACUTE: CONTACT WITH SKIN WILL CAUSE
SEVERE BURNS, EYES, NERVOUS SYSTEM DEPRESSION. CHRONIC: MAY EFFECT
HEART, LIVER AND KIDNEYS.
Effects of Overexposure:ACUTE: CONTACT WITH SKIN WILL CAUSE SEVERE
BURNS, EYES, NERVOUS SYSTEM DEPRESSION. CHRONIC: MAY EFFECT HEART,
LIVER AND KIDNEYS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE PERSON TO FRESH AIR. ADMINISTER ARTIFICIAL
RESPIRATION IF BREATHING HAS STOPPED. EYES: FLUSH WITH WATER AT
LEAST 15 MINUTES WITHIN A 1 MINUTE PERIOD OF CONTACT. SKIN: REMOVE
CONTAMI NATED CLOTHES. WASH AREA WITH WATER. INGESTION: DO NOT
INDUCE VOMITING; GIVE PLENTY OF WATER. SMALL AMOUNTS MAY BE LETHAL.
SEEK MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Lower Limits:NOT EST.
Upper Limits:NOT EST.
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CO2.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING, INCLUDING NIOSH
APPROVED SELF-CONTAINED BREATHING APPARATUS. TREAT AS HYDROCARBON
FIRE.
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION MAY PRODUCE
HYDROGEN CHLORIDE VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:IF OUTDOORS, ADD SAND, EARTH OR OTHER SUITABLE
ABSORBENT TO SPILL AREA. KEEP PRODUCT OUT OF SEWERS AND WATER
COURSES BY DIKING OR IMPOUNDING. INSIDE SPILLAGE: ELIMINATE ALL
IGNITION SOURCES AND REMOVE WITH ABSORBENT MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 80F (27C) OR BELOW
32F (0C). REASONABLE CARE AND PRECAUTIONS WHEN HANDLING THIS
MATERIAL ARE STRONGLY RECOMMENDED.
Other Precautions:THIS CONTAINER MAY BE HAZARDOUS WHEN EMPTIED. EMPTIED
CONTAINERS MAY RETAIN PRODUCT RESIDUES (VAPOR OR LIQUID). USE IN
WELL VENTILATED AREAS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ORGANIC SOLVENTS.
Ventilation:MECHANICAL SUFFICIENT TO MAINTAIN LEVELS OF CONCENTRATION
BELOW TLV OF ANY CONSTITUENTS
Other Protective Equipment:PROTECTIVE CLOTHING: APRON OR SPLASH GUARD
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:T4
Boiling Pt:B.P. Text:102F,39C
Melt/Freeze Pt:M.P/F.P Text:32
Vapor Pres:335 @ 20C
Vapor Density:>1
Spec Gravity:1.20-1.22
Viscosity:A (BUBBLE)
Evaporation Rate & Reference:<1 (WATER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:MILKY, VISCOUS LIQUID WITH SOLVENT ODOR.
Percent Volatiles by Volume:97
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
COAL TAR INSULATION, STRONG OXIDIZERS.
Stability Condition to Avoid:OPEN SPARKS AND FLAMES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY CAUSE
HYDROGEN CHLORIDE VAPORS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. DISPOSAL RECOMMENDATIONS APPLY TO THE
ORIGINAL MATERIAL AND ITS CONTAINER; NOT ANY MATERIALS WHICH ARE A
WASTE BY-PRODUCT OF THE USERS' OPERATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EAS-7 EPOXY HARDENER PART B
Kit Part:Y
CAGE:0L872
CAGE:8L872
CAGE:0L872
============= Composition/Information on Ingredients =============
Ingred Name:POLYAMIDES LD50: (ORAL, RAT) > 5000 MG/KG
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PHENOLS
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SKIN SENSITIZATION. CAN BE
CORROSIVE TO EYE TISSUE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMEDIATELY WITH WATER FOR AT LEAST 15 MINUTES.
CONSULT MD. SKIN: WASH WITH SOAP AND WATER. FLUSH WITH WATER.
INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN IF NECESSARY.
INGESTION: IF CONSC IOUS GIVE COPIOUS AMOUNTS OF WATER.
GETIMMEDIATE MEDICAL ATTENTION. DO NOT INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point:>300F,>149C
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:KEEP AWAY FROM SPARKS.
================== Accidental Release Measures ==================
Spill Release Procedures:COLLECT SMALL SPILLS ON ABSORBENT MATERIAL.
DAM LARGE SPILLS AND RECOVER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM SPARKS, HEAT AND COLD.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC
VAPORS IN CONFINED AREAS.
Ventilation:LOCAL EXHAUST IN CONFINED AREAS.
Other Protective Equipment:EYE WASH AND SAFETY SHOWER .
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
EYE PROT: FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:SLIGHT
Appearance and Odor:AMBER LIQUID WITH AMINE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR LANDFILL ACCORDING TO FEDERAL,
STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DELTA ROCK WOOL BLOWING FIBRE
Preparer's Name:WJ BRAYMAN
CAGE:15270
CAGE:15270
============= Composition/Information on Ingredients =============
Ingred Name:FIBERGLASS (FIBROUS GLASS); (MINERAL WOOL FIBER) %: 97-99.9
CAS:65997-17-3
Fraction by Wt: <99.9%
OSHA PEL:5 MG/M3 RESP DUST
ACGIH TLV:10 MG/M3 (<7MICRONS)
Ingred Name:UREA EXTENDED PHENOL-FORMALDEHYDE RESIN CURED; (PHENOLIC
CURED RESIN) %: 0.001-0.9
CAS:25104-55-6
Fraction by Wt: <0.9%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PETROLEUM HYDROCARBON %: 0.01-0.5
CAS:50854-94-9
Fraction by Wt: <0.5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUP DAT: THERE REMAIN MANY QUESTIONS ABOUT EFTS OF OTHER
CARCIN EXPOS IN WORK PLACE, OTHER JOBS WHICH WORKER (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: MIGHT HAVE HELD, & CIGARETTE SMOKING.
RTECS #:9999999ZZ
Ingred Name:HYGIENE PRACTICES: RINSE WASHER AFTER USE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: THE RELEASE OF MINERAL FIBERS
DURING NORM HNDLG MAY CAUSE SHORT TERM IRRIT TO NOSE &/THROAT.
SKIN: MAY CAUSE TRANSITORY MECH DERM. SKIN ABSORPTION DOES NOT
OCCUR. EYE: DIRECT CONT WILL CAUSE ME CH IRRIT. INGEST: UNLIKELY TO
OCCUR. CHRONIC: ABSENCE OF DISEASE IN VAST MAJORITY OF WORKERS
EXPOSED (EFTS OF OVEREXP)
Explanation of Carcinogenicity:MINERAL WOOL FIBER: IARC MONOGRAPHS,
VOLUME 43, PAGE 152, 1988: GROUP 2B.
Effects of Overexposure:HLTH HAZ: TO MINERAL WOOL FIBER DURING THE LAST
50 YRS SUGGESTS THAT MINERAL WOOL FIBER PRODS POSE LITTLE, IF ANY,
HLTH RISK TO HUMANS. HOWEVER, A RECENT RPT OF SLIGHT EXCESS OF
CANCER IN INSULATION F ACTORY WORKERS WITH 30/MORE YRS SINCE FIRST
EXPOS TO MINERAL WOOL FIBER MFG ENVIRON MERITS FURTHER STUDY. (SUP
DAT)
Medical Cond Aggravated by Exposure:PREEXISTING UPPER RESPIRATORY AND
LUNG DISEASES MAY BE AGGRAVATED BY DUST. THE PRODUCT IS A
MECHANICAL IRRITANT FOR SKIN, EYES, THROAT, AND UPPER RESPIRATORY
SYSTEM.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM EXPOSURE. DRINK WATER TO CLEAR THROAT &
BLOW NOSE TO EVACUATE FIBERS. SKIN: FREQUENT WASHING OF SKIN
W/WATER TO REMOVE ACCUMULATED FIBERS WILL MINIMIZE IRRIT. IF IRRIT
PERSISTS CONS ULT MD. TREAT AS MECHANICAL IRRITANT. EYES: FLUSH
W/FLOWING WATER UNTIL IRRITATION STOPS (FOR AT LEAST 15 MIN). IF
SYMPTOMS PERSIST, SEEK MEDICAL ATTENTION. INGEST: CALL MD
IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point:INCOMBUSTIBLE
Extinguishing Media:WATER, FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NO UNUSUAL FIRE AND EXPLOSION HAZARDS.
RESIN WILL PYROLYZE AT SUSTAINED TEMPERATURES ABOVE 500F.
================== Accidental Release Measures ==================
Spill Release Procedures:NORMAL CLEAN-UP PROCEDURES. AVOID CREATING
DUST.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP MATERIALS UNDER COVER, DRY AND
MINIMIZE THE GENERATION OF DUST.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A MASK DESIGNED FOR NUISANCE TYPE DUSTS SUCH
AS NIOSH APPROVED 3M MODEL 9900, MODEL 8710, OR ITS EQUIVALENT.
Ventilation:USE SUFFICIENT NATURAL OR MECHANICAL VENTILATION TO
MAINTAIN AIRBORNE DUST CONCENTRATION BELOW TLV.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH & DELUGE
SHOWER . WEAR LONG-SLEEVED, LOOSE-FITTING CLTHG, & HEAD COVERING.
Work Hygienic Practices:WASH WORK CLOTHES SEPARATELY FROM OTHER CLTHG
TO PVNT POSS MINERAL WOOL FIBER MIGRATION TO OTHER CLOTHES. (ING 6)
Supplemental Safety and Health
APPEAR/ODOR: CAST; NO APPRECIABLE ODOR. HAZ DECOMP PROD: NITROGEN,
CARBON PARTICULATES & WATER. EFTS OF OVEREXP: THIS RPT MUST BE
CAREFULLY BALANCED AGAINST LGE BODY OF SCIENTIFIC INFO INVOLVING
HUMAN & ANIMAL STUDIES WHERE NO INCR RISK OFDISEASE IS SUGGESTED.
IN ALL OF EPIDEMIOLOGY (WORK PLACE) STUDIES, (ING 4)
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:>2000F,>109
Spec Gravity:VARIABLE
Solubility in Water:NONE
Appearance and Odor:LIGHT BROWN W/YELLOWISH CAST TO A MEDIUM
GREEN-BLACK W/MIXED YELLOWISH (SUP DAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BINDER (RESIN) BURNS/DECOMPOSES IN A
FIRE CAUSING ACRID SMOKE. DECOMP PRODS ARE OXIDES OF CARBON, OXIDES
OF (SUP DAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:MINERAL WOOL FIBER PRODUCTS ARE GENERALLY
CLASSIFIED AS A NONHAZARDOUS WASTE & DISPOSAL MAY BE IN A LANDFILL
FOR NONCRITICAL MATERIALS. LOCAL REGULATIONS SHOULD BE CONSULTED.
DISPOSE OF I/A/W LOCAL, S TATE & FEDERAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SIMPLEX MULTI-PURPOSE CLEANER SX #15930
CAGE:0DAC4
CAGE:0DAC4
CAGE:85884
============= Composition/Information on Ingredients =============
Ingred Name:PROPASOL P
CAS:1569-01-3
RTECS #:UB9351000
Fraction by Wt: 21.5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMMONIUM HYDROXIDE (CERCLA)(SARA 313)
CAS:1336-21-6
RTECS #:BQ9625000
Fraction by Wt: <4.5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:35 MG/M3
ACGIH TLV:STEL 24 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: CAUSES IRRITATION. SKIN: MAY
CAUSE IRRITATION DEPENDING ON DEGREE EXPOSURE. INGESTION: CAN CAUSE
IRRITATION/NAUSEA/STOMACH DISTRESS. INHALATION: CAN CAUSE
IRRITATION TO MOUTH/THROAT/AIRWAYS, ESPE CIALLY FOR SENSITIVE
PEOPLE.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH IMMED W/LOTS COOL RUNNING WATER. REMOVE CONTACTS &
FLUSH AGAIN. SKIN: FLUSH W/WATER THEN WASH W/SOAP & WATER.
INGESTION: RINSE MOUTH. DRINK 1-2 LARGE GLASSES WATER. DON'T INDUCE
VOMITING. N EVER GIVE ANYTHING BY MOUTH TO UNCONSCIOUS PERSON.
INHALATION: REMOVE TO FRESH AIR. IF INGESTED/PERSISTENT EYE/SKIN
IRRITATION CALL POISON CONTROL OR DR IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:108F,42C
Fire Fighting Procedures:PRODUCT DOES NOT SUPPORT COMBUSTION.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE/DAM LARGE SPILLS. PUMP TO CONTAINERS OR
SOAK UP ON INERT ABSORBENT. FLUSH RESIDUE TO SANITARY SEWER.
RECOVER MATERIAL IF POSSIBLE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP DRY. DON'T STORE IN WET OR MOIST
AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID BREATHING MISTS OR VAPORS OF THIS PRODUCT.
Supplemental Safety and Health
*PH = 11.2-12.5
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Spec Gravity:1.021
pH:*
Solubility in Water:COMPLETE
Appearance and Odor:BRIGHT YELLOW COLOR, LEMON - AMMONIA ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NK
Stability Condition to Avoid:DO NOT MIX WITH ANYTHING BUT WATER.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT STATE, LOCAL AUTHORITIES FOR
RESTRICTIONS ON DISPOSAL OF CHEMICAL WASTE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ASPHALT EMULSION CRS-2H
CAGE:0USJ0
CAGE:0USJ0
============= Composition/Information on Ingredients =============
Ingred Name:NON HAZARDOUS INGREDIENTS. TLV:5 MG/M3 (ASPHALT FUMES)
OSHA PEL:N/K
ACGIH TLV:SEE ING
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HEATED PRODUCT MAY CAUSE IRRITATION TO
EYES, LUNGS OR SKIN AFTER PROLONGED OR REPEATED EXPOSURE. HOT
ASPHALT CAN CAUSE THERMAL BURNS AND UNHEATED ASPHALT CAN CAUSE
IRRITATION. OVER EXPOSURE TO FUMES O F HEATED PRODUCT SHOULD BE
AVOIDED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:IMMED WASH W/FRESH WATER FOR @ LEAST 15 MINS & GET MED
ATTN. SKIN, COOL PROD:REMOVE CONTAMD CLTHG AS SOON AS POSS. CLEAN
EXPOS SKIN W/WATERLESS HAND CLEANER, FOLLOWED BY SOAP & WATER. IF
IRRIT PE RSISTS, CONSULT PHYS. SKIN, HOT PROD:IFEXPOS TO HOT
ASPHALT IMMED COOL W/COOL WATER. DO NOT ATTEMPT TO REMOVE ASPHALT
BUT CONTINUE TO COOL EXPOS AREAS W/COLD PACKS & SEEK MED ATTN.
(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F,>93C
Extinguishing Media:USE WATER SPRAY, DRY CHEMICAL, FOAM OR CARBON
DIOXIDE.
Fire Fighting Procedures:NONE KNOWN. USE NIOSH/MSHA APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE. AVOID BREATHING VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL IMMED TO SMALLEST AREA POSS.
RECOVER BY VACUMMING/BY MECH MEANS. RESIDUAL FLUID SHOULD BE SOAKED
UP BY USE OF ABSORB MATL. NONRECYCLABLE PROD & CONTAMD SOILS &
OTHER MATL SHOULD BE PICKE D UP & PLACED IN PROPER CNTNRS FOR STOR&
(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT HEAT TO BOILING OR ALLOW TO
FREEZE, EMULSION WILL BREAK AND SEPARATE. SKIN CONTACT SHOULD BE
MINIMIZED.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED FOR NORMAL CNDTNS OF USE. IF
OPERATING CNDTNS CAUSE HIGH VAPOR CONC USE NIOSH/MSHA APPROVED
RESPIRATOR.
Ventilation:SUFFICIENT TO PREVENT ACCUMULATION OF FUMES.
Other Protective Equipment:LONG SLEEVE CLOTHING IS RECOMMENDED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC:INHAL:REMOVE INDIVIDUAL TO FRESH AIR. IF BRTHNG STOPS,
ADMIN ARTF RESP. INGEST:DO NOT INDUCE VOMIT. GIVE PLENTY OF WATER
BUT DO NOT ATTEMPT TO GIVE LIQUID TO AN UNCONSCIOUS PERSON. CONT
PHYS IMMED. SPILL PROC:ULTIMATE DISP. AVOID WASHING,
DRAINING/DIRECTING MATERIAL TO STORM OR SANITARY SEWERS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:1.0-1.1 @25C
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:DISPERSIBLE
Appearance and Odor:BROWN TO BLACK LIQUID OR SEMISOLID WITH AROMATIC
HYDROCARBON ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:HEAT, FLAME OR SPARK. DO NOT HEAT TO
BOILING POINT TO AVOID FOAMING.
Hazardous Decomposition Products:COMBUSTION MAY FORM CARBON DIOXIDE,
CARBON MONOXIDE, SULFUR DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:RECYCLE AS MUCH OF RECOVERABLE PROD AS POSS.
DISPOSE OF NONRECYCLABLE MATERIAL BY COMPLYING WITH FEDERAL, STATE
AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EUCO K-MENT
Preparer's Name:ROBERT J CROUSE
CAGE:EUCLI
CAGE:EUCLI
============= Composition/Information on Ingredients =============
Ingred Name:PORTLAND CEMENT, CONTAINS: TRICALCIUM SILICATE, DICALCIUM
SILICATE, TRICALCIUM ALUMINATE, TETRACALCIUM ALUMINOFERRATE
CAS:65997-15-1
RTECS #:VV8770000
Fraction by Wt: <100%
Other REC Limits:50 MPPCF (MSHA)
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:GYPSUM
CAS:13397-24-5
RTECS #:MG2360000
Fraction by Wt: <100%
Other REC Limits:5 MG/CUM RESP DUST
ACGIH TLV:10 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: BRONCHITIS & EMPHYSEMA.
EYES: BURNING & CORNEAL EDEMA. SKIN: IRRITATION, BURNS, TISSUE
DAMAGE. INGESTION: CAUSTIC BURNS IN MOUTH, ESOPHAGUS, STOMACH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, BURNS
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE TO FRESH AIR. GIVE OXYGEN IF NECESSARY.
SKIN: WASH AREA TWICE W/SOAP & WATER. INGESTION: GIVE MILK/WATER.
DON'T INDUCE VOMITING. DON'T GIVE ANYTHING BY MOUTH TO UNCONSCIOUS
PERSON. EY ES: FLUSH FOR 15 MINUTES. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Unusual Fire/Explosion Hazard:DUST IN A CLOSED AREA MAY EXPLODE.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP & DISPOSE OF IN STANDARD LANDFILL.
======================Handling and Storage ======================
Handling and Storage Precautions:ALWAYS STORE MATERIAL ON PALLETS IN A
DRY LOCATION.
Other Precautions:SHELF LIFE ONE YEAR UNDER CAREFUL STORAGE CONDITIONS.
IF BAGS TAKE A WAREHOUSE SET, ROLL ON SIDE TO LOOSEN MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DUST MASK
Ventilation:FRESH AIR SUPPLY
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:3-3.15
Appearance and Odor:GREY W/NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:838 2194 EKTACOLOR RA DEVELOPER REPLENISHER WORKING SOLUTION
Kit Part:Y
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 65-70%
Ingred
Name:4-(N-ETHYL-N-2-METHANESULFONYLAMINOETHYL)-2-METHYLPHENYLENEDIA
MINE
CAS:25646-71-3
RTECS #:PB0431000
Fraction by Wt: 20-25%
Ingred Name:LITHIUM SULFATE
CAS:10377-48-7
RTECS #:OJ6419000
Fraction by Wt: 5-10%
Ingred Name:POTASSIUM SULFITE
CAS:10117-38-1
RTECS #:WT3530000
Fraction by Wt: <1%
Ingred Name:SULFUR DIOXIDE (SARA III) RELEASED BY PART B & WORKING
SOLUTION. LISTED TO COMMUNICATE EXPOSURE LIMITS.
CAS:7446-09-5
RTECS #:WS4550000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 PPM
ACGIH TLV:2 PPM/5 STEL; 9394
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 400 MG/KG
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. MAY CAUSE TRANSIENT EYE IRRITATION. SKIN
CONTACT MAY CAUSE IRRITATION. MAY CAUSE ALLERGIC SKIN REACTION.
EXPECTED TO BE A LOW INGESTION HAZARD. MAY CAUSE IRRITATION OF THE
GASTROINTESTINAL TRACT.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION, SKIN IRRITATION, ALLERGIC SKIN
REACTION, GI TRACT IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMMEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER IF ALLOWABLE WITH LARGE AMOUNTS
OF WATER. OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT
MATERIAL, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN
SURFACE TO REMOVE RESIDUA L CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH EYES, SKIN AND
CLOTHING. USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER
HANDLING. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:THE ROUTINE USE OF A NONALKALINE (ACID) TYPE OF HAND
CLEANER AND REGULAR CLEANING OF WORKING SURFACES WILL HELP MINIMIZE
THE POSSIBILITY OF A SKIN REACTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
================== Physical/Chemical Properties ==================
HCC:B3
NRC/State Lic Num:NONE
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.03
pH:10.8
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT YELLOW LIQUID, STRONG AMINE ODOR
Percent Volatiles by Volume:95-100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE WITH COMMON MATERIALS AND CONTAMINANTS WITH WHICH THE MATERIAL MAY
REASONABLY COME INTO CONTACT.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. MAY REQUIRE NEUTRALIZATION IF PH
< 2.0 OR PH > 12.5. DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE ANDLOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MERCURY
CAGE:62910
CAGE:62910
============= Composition/Information on Ingredients =============
Ingred Name:MERCURY (SARA III)
CAS:7439-97-6
RTECS #:OV4550000
Fraction by Wt: 100%
OSHA PEL:S, C, 0.1 MG/M3
ACGIH TLV:S, 0.05 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Health Hazards Acute and Chronic:CHROMIC: EXPOSURE THROUGH ANY ROUTE
CAN PRODUCE CINTRAL NERVOUS SYSTEM DAMAGE. MAY CAUSE MUSCLE
TREMORS, PERSONALITY & BEHAVIOR CHANGES, METALLIC TASTE, LOOSENING
OF THE TEETH, DIGESTIVE DISORDERS, SK IN RASHES & KIDNEY DAMAGE.
ACUTE: SEE "SYMPTOM OF OVEREXPOSURE"
Effects of Overexposure:INHALE:HIGHLY TOXIC VIA THIS ROUTE DUE TO
MENBRANE PERMEABILITY. CENTRAL NERCOUS SYSTEM IMPAIRMENT ARE
SYMPTOMS. CHEST PAINS, DYPSNEA, & COUGHING, KIDNEY DAMAGE;
INGEST:ITS ABILITY TO PENETRATE TISSUE S PRESENTS SOME HAZARD.
======================= First Aid Measures =======================
First Aid:INHALE:REMOVE TO FRESH AIR, KIF NOT BREATHING, GIVE
ARTIFICIAL RESPIRATION, IF BREATHING IS DIFFICULT, GIVE OXYGEN,
CALL A PHYSICIAN; INGEST:GET MIDICAL ATTENTION IMMEDIATELY, NEVER
GIVE ANYTHING BY M OUTH TO AN UNCONSCIOUS PERSON; SKIN:FLUSH SKIN
WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES WHILE REMOVING
CONTAMINATED CLOTHING & SHOES; EYE:WASH WITH PLENTY OF WATER FOR 15
MINUTES LIFTING EYELIDS.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE ANY MEDIA SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR SELF-CONTAINED
BREATHING APPARATUS WITH FULL FACEPIECE OPERATED IN THE PRESSURE
DEMAND OR OTHER POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:NONE STATED.
================== Accidental Release Measures ==================
Spill Release Procedures:DO NOT FLUSH TO THE SEWER. PROVIDE FORCED
VENTILATION TO DISSIPATE FUMES. WEAR RESPIRATORY EQUIPMENT SUITABLE
FOR TOXIC METAL FUMES. TRANSFER TO A CLOSED CONTAINER, PREFERABLY
GLASS OR PLASTIC FOR STO RAGE BEFORE RECLAMATION OR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN COOL,DRY PLACE AWAY FROM HEAT
& IGNITION SOURCES, KEEP IN A TIGHTLY CLOSED CONTAINER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF THE TLV IS EXCEEDED, WEAR A SUPPLIED AIR,
FULL-FACEPIECE RESPIRATOR, AIRLINED HOOD, OR SELF-CONTAINED
BREATHING APPARATUS.
Ventilation:USE LOCAL AND/OR GENERAL EXHAUST IS RECOMMENDED TO KEEP
BELOW TLV.
Other Protective Equipment:IMPERVIOUS APRON COVERALLS, ETC.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:674F/356.7C
Melt/Freeze Pt:M.P/F.P Text:-38F/-38.8C
Vapor Pres:1 @ 259F
Spec Gravity:13.55
Solubility in Water:INSOLUBLE
Appearance and Odor:SILVER-WHITE HEAVY, MOBILE LIQUID METAL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACETYLENES, AMMONIA, ETHYLENE OXIDE, METAL OXIDES, METHYL SILANE,
STRONG OXIDANTS, METAL CARBONYLS.
==================== Disposal Considerations ====================
Waste Disposal Methods:PACKAGE UNRECLAIMABLE MATERIAL FOR DISPOSAL IN A
RCRA-APPROVED WASTE FACILITY. COMPLY WITH FEDERAL,STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TRIDENT 2002
CAGE:0U4X9
CAGE:0U4X9
============= Composition/Information on Ingredients =============
Ingred Name:PYROSULFUROUS ACID, DISODIUM SALT; (SODIUM METABISULFITE)
CAS:7681-57-4
RTECS #:UX8225000
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:CAUSES IRRITATION. SKIN:CAUSES
IRRITATION. INHALATION:RESPIRATORY TRACT IRRITATION. INGESTION:NOT
CONSIDERED TOXIC.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NOT KNOWN.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH WATER FOR AT LEAST 15 MINUTES-OBTAIN MEDICAL
ATTENTION. SKIN:FLUSH THOROUGHLY WITH WATER. INGESTION:DRINK SMALL
AMOUNTS OF WATER AND OBTAIN MEDICAL ATTENTION. INHALATION:REMOVE TO
FRES H AIR.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATERSPRAY, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:IRRITATING VAPORS MAY BE EMITTED DURING A
FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:NEUTRALIZE SPILLED MATERIAL WITH LIME OR SODA
ASH. SQUEEGEE AND COLLECT OR VACUUM SPILLAGE AND PLACE IN CONTAINER
FOR DISPOSAL. FLUSH SPILL AREA WITH WATER.
Neutralizing Agent:NEUTRALIZE SPILLED MATERIAL WITH LIME OR SODA ASH.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, PROTECTED LOCATION.
KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:CLEAN UP SPILLS IMMEDIATELY. RINSE CONTAINER BEFORE
REUSE OR DISPOSAL. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NOT NORMALLY REQUIRED.
Ventilation:LOCAL EXHAUST:NOT NORMALLY REQUIRED. MECHANICAL:NOT
NORMALLY REQUIRED, EXCEPT IF APPLICABLE TLV IS EXCEEDED.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER . PROTECTIVE CLOTHING RECOMMENDED.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Spec Gravity:1.315 (H*2O=1)
pH:4.4
Evaporation Rate & Reference:-1 (WATER=1)
Solubility in Water:COMPLETE
Appearance and Odor:PINK LIQUID WITH A SULFITE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, STRONG ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:SULFUR OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . DISPOSE OF AT AN APPROVED CHEMICAL WASTE REPROCESSING
FACILITY. SMALL QUANTITIES MAY BE DISPOSED OF IN THE SANITARY SEWER
AFTER NEUTRA LIZATION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PR-1560-M, PART B
CAGE:DO563
CAGE:83574
CAGE:DO563
============= Composition/Information on Ingredients =============
Ingred Name:CHLOROBENZENE (SARA III)
CAS:108-90-7
RTECS #:CZ0175000
Fraction by Wt: 48%
OSHA PEL:75 PPM
ACGIH TLV:10 PPM; 9192
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:NAPHTHA (PETROLEUM SPIRITS OR BENZIN)
CAS:8030-30-6
RTECS #:SE7555000
Fraction by Wt: 8%
OSHA PEL:100 PPM
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 3%
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL BENZENE (SARA III)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 2%
OSHA PEL:100 PPM/125 STEL
ACGIH TLV:100 PPM/125STEL 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:IRRIT OF NOSE, THROAT & EYES; DIZZINESS.
INGESTION: MAY CAUSE KIDNEY & LIVER DAMAGE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LUKE WARM WATER FOR 15 MINS. IF SYMPTOMS
PERSIST CONSULT PHYS. SKIN: WASH W/SOAP & WATER. IF SYMPTOMS
PERSIST, CONSULT PHYS. INHALATION: REMOVE TO FRESH AIR. CONSULT
PHYSICIAN. INGESTION : DON'T INDUCE VOMITING. CONSULT PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:70F PMCC
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER FOG
Fire Fighting Procedures:USE AIR-SUPPLIED RESPIRATOR. USE WATER TO COOL
CONTAINERS.
Unusual Fire/Explosion Hazard:HIGH TEMPERATURES MAY CAUSE PRESSURE
BUILDUP IN CLOSED CONTAINERS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. WEAR AIR-SUPPLIED
RESPIRATOR FOR MAJOR UNVENTILATED SPI COVER WITH ABSORBANT. SCOOP
INTO CONTAINERS. CLEAN RESIDUE WITH 1,1,1-TCHLOROETHANE.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE AN AIR-SUPPLIED RESPIRATOR FOR CONFINED
AREA.
Ventilation:PROVIDE MECHANICAL (GENERAL) VENTILATION TO KEEP <TLV
Supplemental Safety and Health
MSDS DATE: 04/07/85
================== Physical/Chemical Properties ==================
Spec Gravity:.26
Solubility in Water:NEGLIGIBLE
Percent Volatiles by Volume:75%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:OXIDES OF CARBON; HCL
==================== Disposal Considerations ====================
Waste Disposal Methods:EPA WASTE NO. D-001. DISPOSE OF SPILLATE IN
COMPLIANCE WITH STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PHENYLIC ACID
CAGE:63415
CAGE:63415
============= Composition/Information on Ingredients =============
Ingred Name:PHENOL
CAS:108-95-2
RTECS #:SJ3325000
Fraction by Wt: 100%
OSHA PEL:S, 5 PPM
ACGIH TLV:S, 5 PPM; 8990
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:SYSTEMIC TOXICITY. SYMPT-MUSC WEAKNESS,DIGEST &
NEURO EFFECTS.EYES-BURN;INHAL/INGEST-HARM;SKN-POISON
======================= First Aid Measures =======================
First Aid:EYE-FLUSH W/WATER,GET MED ATTN. SKIN-FLUSH W/WATER,WASH
W/POLYETH GLYCOL 300 OR 10% SODIUM BICARB;GET MED ATTN. INHAL-GET
TO FRESH AIR & MED ATTN. INGEST-GIVE CASTOR OIL,VEG OIL OR ACTIVAT
CHARCOAL SL URRY;INDUCE VOMIT;GET IMMED MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:175F/79C/SETA CC
Extinguishing Media:WATER SPRAY,DRY CHEM,CARBON DIOXIDE
Fire Fighting Procedures:WEAR SLF-CONTND BREATH APPAR & PROTECTIVE
CLOTHING
Unusual Fire/Explosion Hazard:THIS MATL,IN SUFFICIENT QTY & REDUCED
PARTICLE SIZE CAN CREATE A DUST EXPLOSION.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP & SAFELY PACKAGE FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:MATL IS COMBUST,KEEP AWAY FROM HEAT &
FLAME. KEEP FROM CONTACT W/OXIDIZING MATLS. KEEP CONTAINER TIGHTLY
CLOSED. KEEP AWAY FROM ALKALIES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPRVD ORGANIC VAPOR RESPIRATOR IF NEEDED
Ventilation:LOCAL EXHAUST
Other Protective Equipment:PROTECTIVE CLOTHING
Supplemental Safety and Health
MSDS DTD 1/87
================== Physical/Chemical Properties ==================
HCC:T3
NRC/State Lic Num:NOT RELEVANT
Spec Gravity:1.06
Solubility in Water:MODERATE
Appearance and Odor:COLORLESS CRYSTALS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALIES,NITRIC ACID,STRONG OXIDIZERS,NITROBENZENE,ALCL*3
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CARBON DIOXIDE & CARBON MONOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:IAW ALL APPLICABLE LOCAL,STATE & FED REGS. IF
PERMITTED,INCINERATE OR CONTRACT W/LICENSED CHEM WASTE DISPOSAL
AGENCY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:THORTEX CERAMI-TECH CR ACTIVATOR, 2990/102
Kit Part:Y
Preparer's Name:A HILL
CAGE:EWLTD
CAGE:EWLTD
============= Composition/Information on Ingredients =============
Ingred Name:ALKYLATED POLYAMINE ADDUCT
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CORROSIVE - MAY CAUSE BURNS.
TOXICOLOGICAL PROPERTIES: PROLONGED SKIN CONTACT MAY CAUSE
IRRITATION AND SENSITIZATION.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . SKIN: WASH WITH SOAP AND WATER. EYE: FLUSH WITH COPIOUS
QUANTITIES OF CLEAN WATER FOR AT LEAST 15 MINUTES. INGESTION: DO
NOT INDUCE VOMITING - SEEK MEDICAL ADVICE.
===================== Fire Fighting Measures =====================
Flash Point:>248F,>120C
Extinguishing Media:EXTINGUISH FIRES WITH FOAM, WATER MIST, CARBON
DIOXIDE OR DRY POWDER.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:DO NOT ALLOW TO ENTER WATER COURSES OR WASTE
WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT EAT OR DRINK DURING USE -
OBSERVE GOOD INDUSTRIAL HYGIENE. STORE IN SEALED CONTAINERS AT
TEMPERATURES BETWEEN 10C AND 30C.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EYE PROT: AND FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>500F,>260C
Spec Gravity:1.050
Solubility in Water:INSOLUBLE
Appearance and Odor:VISCOUS AMBER LIQUID, AMMONIACAL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR DISPOSE OF IN AN APPROVED
INDUSTRIAL WASTE SITE. DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ELECTROGRAPHIC DEVELOPER 8922-424.
CAGE:60777
CAGE:60777
============= Composition/Information on Ingredients =============
Ingred Name:NON HAZARDOUS INGREDIENTS.
Fraction by Wt: 100%.
ACGIH TLV:UNKNOWN.
===================== Hazards Identification =====================
Effects of Overexposure:CAUTION:NOT FOR INTERNAL USE.CONTAINS PETROLEUM
DISTILLATE.IF ACCIDENTALLY INGESTED,CALL DR. IMMED.
================== Accidental Release Measures ==================
Spill Release Procedures:ALLOW TO EVAPORATE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED & STORE IN A
& ALL PURPOSE CANISTER MASK.
Other Precautions:STORE AWAY FROM HEAT & LIGHT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR ALL-PURPOSE CANISTER MASK.
Ventilation:AS REQUIRED TO CONTROL TLV IN AIR.
Other Protective Equipment:FACE SHIELD,OVERALLS
Supplemental Safety and Health
EFFECTS OF OVEREXPOSURE (CONT'D):AVOID PROLONGED CONTACT WITH SKIN.
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:PUT IN APPROVED STORAGE CONTAINER & SHIP TO AN
APPROVED DISPOSAL AREA.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CRONALAR RAPID ACCESS DEVELOPER PART B, RAD-B
Kit Part:Y
CAGE:0ERJ7
CAGE:82348
CAGE:0ERJ7
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2,2'IMINODI-; (DIETHANOLAMINE) (SARA III) LD50:
(ORAL, RAT) 1820 MG/KG
CAS:111-42-2
RTECS #:KL2975000
Fraction by Wt: 15-40%
OSHA PEL:3 PPM
ACGIH TLV:3 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:POTASSIUM HYDROXIDE (SARA III) LD50: (ORAL, RAT) 365
MG/KG
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 1-5%
OSHA PEL:2 MG/M3, C
ACGIH TLV:2 MG/M3, C
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:1H-INDAZOLE, 5-NITRO-; (5-NITROINDAZOLE)
CAS:5401-94-5
RTECS #:NK7962000
Fraction by Wt: 0.1-1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 40-70%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CAUSES EYE & SKIN BURNS. INHAL OF
MIST/DRIED RESIDUE CAUSES RESP IRRIT & MAY CAUSE PULM EDEMA. INGEST
CAUSES GI IRRIT. TOX EFTS DESCRIBED IN ANIMALS FROM SHORT EXPOS TO
ING 1 BY INHAL, INGEST/SKIN CNT CT INCL LIVER & KIDNEY EFTS. TESTS
W/ING 3 IN BACTERIAL & MAMMALIAN CELL CULTURES DEMONSTRATE
MUTAGENIC ACTIVITY.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:EYE & SKIN BURNS, RESPIRATORY & MUCOUS MEMBRANE
IRRITATION, PULMONARY EDEMA, COUGHING, DERMATITIS, DIFFICULTY
BREATHING, NAUSEA, ABDOMINAL PAIN, JAUNDICE, DIARRHEA.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. IF NOT BRTHG GIVE ARTF RESP. IF
BRTHG DFCLT, GIVE O*2. CALL MD. SKIN:IMMED FLUSH W/PLENTY WATER FOR
@ LEAST 15 MIN WHILE REMOVING CONTAMD CLTHG & SHOES. WASH CLTHG
BEFORE RE USE. CALL MD. EYES:IMMED FLUSH W/PLENTYWATER FOR @ LEAST
15 MIN. CALL MD. INGEST:DO NOT INDUCE VOMIT. GIVE LG AMTS WATER.
NEVER GIVE ANYTHING BY MOUTH TO UNCON PERSON. VOMIT SHOULD NOT BE
(SUDPAT)
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:ANY APPLICABLE TO PRIMARY CAUSE OF FIRE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . EVACUATE PERSONNEL TO A SAFE AREA. KEEP
PERSONNEL REMOVED AND UPWIND OF FIRE.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:REVIEW FIRE & EXPLOS HAZ & SFTY PREC BEFORE
PROCEEDING W/CLEANUP. USE APPROP PERSONAL PROT EQUIP. DIKE SPILL.
PVNT LIQ FROM ENTERING SEWERS, WATERWAYS/LOW AREAS. SOAK UP
W/SAWDUST, SAND, OIL DRY/OTHER ABSORB MATL. NEUT SPILL BOFORE
DISP. (SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN WELL-VENT AREA. KEEP CNTNR
TIGHTLY CLSD. DO NOT STORE/CONSUMD FOOD, DRINK/TOBACCO IN AREA
WHERE THEY MAY BECOME CONTAMD W/THIS MATL.
Other Precautions:USE ONLY WITH ADEQUATE VENTILATION. DO NOT MIX WITH
STRONG ACIDS. AVOID BREATHING VAPORS OR MIST. AVOID CONTACT WITH
EYES AND SKIN. AVOID CONTACT WITH CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED CHEMICAL CARTRIDGE
RESPIRATOR WITH ORGANIC VAPOR CARTRIDGES ONLY IN UNUSUAL SITUATIONS
WHERE TLV MAY BE EXCEEDED.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:EMERGENCY EYE WASH & DELUGE SHOWER MTG ANSI
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
FIRST AID PROC:INDUCED IN CASES OF INGEST OF CORR MATLS/CERTAIN
PETRO-BASED MATLS. ALL CASES OF INGEST SHOULD BE REFERRED IMMED TO
POIS CTL CTR/MD & VOMIT SHOULD NORM BE INITIATED ONLY ON THEIR
ADVICE & BY MEANS THEY SPECIFY. SPILL PROC:FLUSH AREA W/PLENTY
WATER. WASTE DISP METH:PERMITTING AUTH & MAY REQ PRETREATMENT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Spec Gravity:1.06
pH:13.2
Solubility in Water:100 WT%
Appearance and Odor:CLEAR DARK RED LIQUID; MILD FISHY ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE WITH STRONG ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:DECOMPOSES BY REACTION WITH STRONG
ACIDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CLEANED-UP MATL IS RCRA HAZ WASTE.
TREATMENT,STOR, TRANSPORTATION & DISP MUST BE I/A/W APPLIC FED,
STATE & LOCAL REGS. REMOVE NONUSABLE SOLID MATL &/OR CONTAMD SOIL
FOR DISP IN APPRVD & PERMITTED LAND FILL. DISCHARGE TO SEWER REQS
APPROVAL OF (SUPDAT)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:92-15909A6 QUICKSILVER 4-CYCLE MARINE ENGINE OIL
CAGE:GO139
CAGE:88907
CAGE:GO139
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, SOLVENT-DEWAXED LIGHT
PARAFFINIC
CAS:64742-56-9
RTECS #:PY8039500
Fraction by Wt: <95%
OSHA PEL:5 MG/CUM (OIL MIST)
ACGIH TLV:5 MG/CUM (OIL MIST)
Ingred Name:OIL PETROLEUM DISTILLATES, SOLVENT-DEWAXED HEAVY PARAFFINIC
CAS:64742-65-0
RTECS #:PY8038500
Fraction by Wt: <95%
Other REC Limits:5 MG/CUM
OSHA PEL:5 MG/CUM (OIL MIST)
ACGIH TLV:5 MG/CUM (OIL MIST)
Ingred Name:PETROLEUM HYDROCARBONS, SOLVENT DEWAXED RESIDUAL OIL
(PETROLEUM) *92/2*
CAS:64742-62-7
Fraction by Wt: <95%
OSHA PEL:5 MG/CUM (OIL MIST)
ACGIH TLV:5 MG/CUM (OIL MIST)
Ingred Name:INHIBITOR VI IMPROVER
Fraction by Wt: <10%
Ingred Name:ADDITIVES INCLUDING ZINC ALKYL DITHIOPHOSPHATE (<2%).
Fraction by Wt: <1%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: DRYNESS,
CRACKING, DERMATITIS, FOLLICULITIS & IRRITATION. INHALATION:
DROWSINESS, DIZZINESS, HEADACHE, NAUSEA, LUNG IRRITATION & CHEMICAL
PNEUMONITIS. INGESTION: LOW TOXICITY, DEPRESSION, HEADACHE,
DROWSINESS, NAUSEA, VOMITING, DIARRHEA & IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION. SKIN: DRYNESS, CRACKING,
DERMATITIS, FOLLICULITIS & IRRITATION. INHALATION: DROWSINESS,
DIZZINESS, HEADACHE, NAUSEA, LUNG IRRITATION & CHEMICAL
PNEUMONITIS. INGESTION: LOW TOXICITY, DEPRESSION, HEADACHE,
DROWSINESS, NAUSEA, VOMITING, DIARRHEA & IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER. SKIN: WASH W/SOAP & WATER.
INHALATION: REMOVE TO FRESH AIR. INGESTION: DON'T INDUCE VOMITING.
INJECTION: SUBCUTANEOUS INJECTION IS A MEDICAL EMERGENCY. OBTAIN
MEDICAL AT TENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:510F
Extinguishing Media:CO2, DRY CHEMICAL, FOAM OR WATER FOG
Fire Fighting Procedures:WATER MAY CAUSE FROTHING.
Unusual Fire/Explosion Hazard:EMPTY CONTAINERS MAY CONTAIN RESIDUE
WHICH COULD INCLUDE FLAMMABLE OR EXPLOSIVE VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. VENTILATE AREA.
CONTAIN LEAK. ABSORB SMALL SPILLS W/SUITABLE MATERIAL SUCH AS RAGS,
STRAW, OR SAND. REPORT SPILLS AS REQUIRED TO APPROPRIATE
AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE >120F. ELIMINATE IGNITION
SOURCES. AVOID SKIN CONTACT W/USED MOTOR OILS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:APPROVED ORGANIC VAPOR & MIST RESPIRATOR IF
>TLV.
Ventilation:LOCAL EXHAUST: AS REQUIRED. MECHANICAL (GENERAL): IF >TLV.
Other Protective Equipment:FULL PROTECTIVE CLOTHING
Work Hygienic Practices:FOLLOW GOOD HOUSEKEEPING/PERSONAL HYGIENE
PRACTICES. REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE REUSE. WASH
THOROUGHLY.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Density:>1
Spec Gravity:0.89
Evaporation Rate & Reference:(BU AC = 1): <1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER COLOR W/MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS
Stability Condition to Avoid:HIGH HEAT, FLAME, & OTHER SOURCES OF
IGNITION
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL, STATE, & FEDERAL REGULATIONS
BEFORE REUSING, RECLAIMING, RECYCLING OR DISPOSING OF EMPTY
CONTAINERS &/OR WASTE RESIDUES OF THIS PRODUCT. EMPTY CONTAINERS
MAY CONTAIN RESIDUE WHICH COULD INCLUDE FLAMMABLE/EXPLOSIVE
VAPORS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LACQUER SPRAYING YELLOW 13538, ID793310
Preparer's Name:W.A. ELLISON
CAGE:FO127
CAGE:FO127
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:ISOBUTYL ACETATE (SARA III)
CAS:110-19-0
RTECS #:AI4025000
OSHA PEL:150 PPM
ACGIH TLV:150 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:NITROCELLULOSE
CAS:9004-70-0
RTECS #:QW0970000
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
Ingred Name:ISOBUTYL ALCOHOL (SARA III)
CAS:78-83-1
RTECS #:NP9625000
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL ACETATE (SARA III)
CAS:141-78-6
RTECS #:AH5425000
OSHA PEL:400 PPM
ACGIH TLV:400 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VM &P NAPHTHA
(VAPOR PRESSURE 40 MMHG @ 20C)
CAS:8030-30-6
RTECS #:SE7555000
OSHA PEL:500 PPM
ACGIH TLV:300 PPM/1350 MG/CU.M
Ingred Name:N-HEPTANE
CAS:142-82-5
RTECS #:MI7700000
OSHA PEL:500 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9293
Ingred Name:METHYL ISOBUTYL KETONE (SARA III)
CAS:108-10-1
RTECS #:SA9275000
OSHA PEL:100 PPM/75 STEL
ACGIH TLV:50 PPM/75 STEL; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VOC. ORGANIC CMPD 5.3 LB/GAL LESS WATER & NPRS* 636 G/L
LESS WATER VOC. 23.5 LB/GAL SOLIDS 2820 G/L SOLIDS CALCU
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ASPIRATION OF MATERIAL INTO THE LUNGS
CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL. REPEATED EXPSR
TO CRYSTALLINE SILICA MAY CAUSE PNEUMOCONIOSIS A DISABLING LUNG
DISEASE. PROLONGED/REPEATED OVR EXPSR MAY CAUSE PERMANENT BRAIN &
NERVSSYS DAMAGE. INTENTIONAL MISUSE CAN BE HARMFUL OR FATAL.
Explanation of Carcinogenicity:AT TLV THE TI02 MANUFACTURER CONCLUDES
THAT THERE IS NO SIGNIFICIANT HAZARD FOR MAN.
Effects of Overexposure:INGST: GASTRONINTESTINAL
IRRITATION,NAUSEA,VOMITING,& DIARRHEA. INHL:
ANESTHETIC,IRRITATION TO NOSE/THROAT, HEADACHES, DIZZINESS, NAUSEA,
& CONFUSION.; SKIN: MAY CAUSE DEFATTING AND I RRITATIONEYE:
IRRITATION
Medical Cond Aggravated by Exposure:REPEATED EXPOSURE MAY CAUSE
PNEUMOCONIOSIS, A PROGRESSIVELY DISABLING LUNG DISEASE.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/LG AMNTS OF WTR, LIFTING EYELIDS, FOR 15 MIN.
GET MEDICAL ATTENTIONSKIN: WASH AFFECTED AREA W/SOAP & WTR, REMOVE
CONTAM. CLOTHING.GET MED. ATTN. INHAL: REMOVE TO FRESH AIR
IMMEDIATELY,G IVE ARTIFICIAL RESP. IF NECESSARY, KEEPWARM & QUIET,
GET MEDICAL ATTENTION.
INGST: DO NOT INDUCE VOMITING. GET MEDICAL ATTENTION IMMEDIATELY
===================== Fire Fighting Measures =====================
Flash Point:20F/-6.67C
Extinguishing Media:USE NFPA CLASS B FIRE EXTINGUISHERS,CARBON
DIOXIDE,DRY CHEMICAL,ALCOHOL FOAM. POLYMER FOAM IS PREFERRED FOR
LG. FIRES
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS. WATER
MAY BE INEFFECTIVE,MAY BE USED TOCOOL EXPOSED CONTAINERS. IF WATER
IS USED, FOG NOZZLES ARE PREFERRABLE.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIPMENT,SPARKS &FLAME. CLOSED CONTAINERS
MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. DIKE/CONTAIN
SPILLW/INERT MATL. PLACE ABSORBENT DIKING MATL IN COVERED METAL
CONTNR FOR DISPOSAL. USE ONLY NON SPARKNGTOOLS. PREVENT CONTAM. OF
SEWERS, GROUNDWATER, AND STREAMS W/SPILLED MATL OR USED ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 95F. CLOSE CONTNR
AFTER EACH USE. EMPTY CONTNRS MUST NOT BE WASHED/REUSED FOR
NEVER USE PRESSURE TO EMPTY.
Other Precautions:DO NOT TAKE INTERNALLY. CONTAINERS SHOULD BE
GROUNDED/BONDED TO RECEIVING CONTNRDO NOT WELD,BRAZE OR CUT ON
EMPTY CONTAINERS. DRUM IS NOT A PRESSURE VESSEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESTRICTED AREAS US NIOSH APPROVED CHEMICAL
CARTRIDGE RESPIRATOR. SPRAYING USE AMECHANICAL FILTER RESPIRATOR.
CONFINED AREAS USE A NIOSH APPROVED AIR SUPPLIED RESPIRATOR.
Ventilation:LOCAL EXHAUST VENTILATION OR GENERAL DILUTION
Other Protective Equipment:EYE WASH FACILITY, SAFETY SHOWER
Work Hygienic Practices:NONE
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:167-302F
Vapor Density:> AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:77
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, ALKALINE MATERIALS, OXIDIZING MATERIALS
Stability Condition to Avoid:HEAT AND SOURCES OF IGNITION
Hazardous Decomposition Products:BURNING, INCLUDING WHEN HEATED BY
WELDING OR CUTTING, WILL PRODUCE SMOKE, CARBON MONOXIDE AND CARBON
DIOXIDE.
Conditions to Avoid Polymerization:HEAT SPARKS AND FLAME
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE W/FEDERAL,STATE,& LOCAL
LAWSINCINERATE ONLY IN EPA PERMITTED FACILITY. DO NOT INCINERATE
CLSD CONTAINERS. CONTAMINATED ABSORBANTMAY BE DISPOSED IN A
HAZARDOUS WASTE LANDFILL.TRAN SFER LIQ TO COVERED METAL CONTAINERS
FOR DISPOSAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AMBEROL
Preparer's Name:RICHARD J. PETSCHE
CAGE:HO278
CAGE:HO278
CAGE:58380
============= Composition/Information on Ingredients =============
Ingred Name:BENZENESULFONIC ACID, DODECYL-, CMPND W/2,2',2"-NITRILOTRIS
(ETHANOL)(1:1); (TRIETHANOLAMINE SALT OF DODECYL (ING 2)
CAS:27323-41-7
RTECS #:DB6813000
Fraction by Wt: >1%
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ING 1: BENZENE SULFONIC ACID)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CAUSES EYE IRRITATION. CHRONIC:
NONE KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:EYES: REDNESS, IRRITATION.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MIN. SEEK
PROMPT MEDICAL ATTENTION. INGEST: DRINK LARGE QUANTITIES OF WATER.
CALL A PHYSICIAN. INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING
(GIVE O*2/ ARTF RESP). SKIN: FLUSH WITH COPIOUS AMOUNTS OF WATER.
SEE MD .
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:EXTINGUISHING MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP SPILL WITH OIL ABSORBENT. FLUSH ANY
RESIDUE WITH WATER. DISCARD USED ABSORBENT IN PROPER RECEPTACLE FOR
LANDFILL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING. KEEP OUT OF REACH
OF CHILDREN.
Other Precautions:FOR INDUSTRIAL AND INSTITUTIONAL USE ONLY. READ AND
FOLLOW ALL LABEL DIRECTIONS AND PRECAUTIONS. DO NOT MIX WITH ANY
OTHER CHEMICALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE.
Other Protective Equipment:NONE
Work Hygienic Practices:NONE
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>190F,>88C
Vapor Density:> 1
Spec Gravity:1.028 (H*2O=1)
Evaporation Rate & Reference:> 1 (BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR AMBER LIQUID WITH A MILD BOUQUET ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:A NONHAZARDOUS WASTE AS DEFINED BY RCRA.
DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATION .
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:SAFETY BOOSTERS
Preparer's Name:MICHAEL CAUSEY (SUPDAT)
CAGE:EO264
CAGE:11239
CAGE:EO264
============= Composition/Information on Ingredients =============
Ingred Name:LEAD TRINITRORESORCINATE; (LEAD STYPHNATE) (MFR CAS #
15245-44-0)
CAS:15345-44-0
RTECS #:OG6425000
Fraction by Wt: 1%
OSHA PEL:0.05 MG/M3, C
ACGIH TLV:0.150 MG/M3
Ingred Name:1-TETRAZENE,1-GUANYL-4-NITROSAMINOGUANYL-; (TETRACENE)
CAS:109-27-3
RTECS #:XF6900000
Fraction by Wt: 0.1%
Ingred Name:BARIUM NITRATE
CAS:10022-31-8
RTECS #:CQ9625000
Fraction by Wt: 1%
OSHA PEL:0.5 MG/M3
ACGIH TLV:0.5 MG/M3
Ingred Name:NITROGLYCERIN; (NG)
CAS:55-63-0
RTECS #:QX2100000
Fraction by Wt: 5-11%
OSHA PEL:S,C, 0.2 MG/M3 STEL
ACGIH TLV:S, 0.46 MG/M3; 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:NITROCELLULOSE
CAS:9004-70-0
RTECS #:QW0970000
Fraction by Wt: 5-11%
Ingred Name:BRASS
Fraction by Wt: 65-85%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE EXPECTED. POSSIBLE IRRITATION
FROM FUMES AND GASES UNDER CERTAIN CONDITIONS SUCH AS EXCESSIVE
FIRING WITH LITTLE AIR MOVEMENT.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:EXCESSIVE EXPOSURE MIGHT CAUSE IRRITATION TO
EYES, SKIN, AND RESPIRATORY SYSTEM. ADVERSE HEALTH EFFECTS ARE NOT
EXPECTED FROM LONG TERM EXPOSURE TO FUMES AND GASES; HOWEVER, GOOD
PERSONAL HYGIENE PRAC TICES ARE ESSENTIAL TO KEEP EXPOSURE TOA
MINIMUM.
Medical Cond Aggravated by Exposure:NONE ANTICIPATED.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/PLENTY OF H*2O FOR @ LST 15 MIN. CONSULT PHYS IF
SYS PERSIST. SKIN:PRACTICE GOOD HYGIENE BY WASH W/SOAP/H*2O AFTER
USING & BEFORE MEALS. INHAL:MOVE TO FRESH AIR. GET MED ATTN IF SYMP
PERS IST. INGEST:GET IMMED MED ATTN. OTHER:SEEK PROMPT MED ATTN IF
PHYS INJURY OCCURS FROM PINS, RIVETS, SHRAPNEL, ETC. FOR BLEEDING
WOUNDS, PLACE CLEAN MATL ON WOUND & APPLY FIRM PRESS. ELEVATE(SUPP
DATA)
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . FLOOD AREA WITH WATER OR KEEP CARTRIDGES
COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:CARTRIDGES CAN EXPLODE IF EXPOSED TO
TEMPERATURES ABOVE 200C.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL DRY PLACE. DO NOT
CRUSH/DROP. KEEP AWAY FROM EXCESS HEAT, ELEC CURRENT, STRONG ACIDS
& OXIDIZERS. NFPA 495 REQ 15FT SEPARATION (SUPDAT)
Other Precautions:USE ONLY IN POWDER ACTUATED TOOLS DESIGNED TO HANDLE
THESE BOOSTERS. EMPLOYEE MUST BE PROPERLY TRAINED AS PRESCRIBED BY
APPLICABLE OSHA REGULATIONS 29 CFR 1910.243 (D) OR 1926.302 (E).
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED PARTICULATE RESPIRATOR (E.G.
3H8710) WHERE AIR MOVEMENT IS INADEQUATE TO MAINTAIN EXPOSURE BELOW
RECOMMENDED LEVELS.
Ventilation:GEN (I.E. NATURAL/MECH INDUCED FRESH AIR MOVEMENT THAT
MAINTAIN VAP CONC BELOW RECOMMEDED LEVEL).
Other Protective Equipment:HEARING PROTECTION: MUFFS OR AURAL INSERTS.
REFER TO APPLICABLE OSHA REGULATION 29 CFR 1910.95 OR 1926.101.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING AND BEFORE
MEALS OR SNACKS.
Supplemental Safety and Health
PREPARER'S NAME: STEVE GERRARD. FIRST AID PROC:WOUND & TRANSPORT IMMED
TO MED FACILITY. WASTE DISP METH: FEDERAL, STATE AND LOCAL
REGULATIONS . HNDLG/STOR PREC: (OR 1 HR FIRE WALL) FROM FLAMMABL E
LIQUIDS, FLAMMABLE SOLIDS, AND OXIDIZERS.
================== Physical/Chemical Properties ==================
HCC:E1
Appearance and Odor:BRASS CASING COLOR CODED ON STAR CRIMP.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND OXIDIZING MATERIALS.
Stability Condition to Avoid:ACIDS, EXCESS HEAT, CRUSHING, AND
ELECTRICAL CURRENTS.
Hazardous Decomposition Products:OXIDES OF NITROGEN, ACRID FUMES, AND
LEAD.
==================== Disposal Considerations ====================
Waste Disposal Methods:MISFIRES/BENT CARTRIDGES/ETC. SHOULD BE STORED
IN CONTR OF H*2O TO WHICH DETERGENT HAS BEEN ADDED AS "WETTING"
AGENT. ONLY PROPER DISP METH IS TO INCINERATE IN SM AMT IN BURNER
SPECIFICALLY DESIGNED F OR DESTROY HAZ AMMUNITION. DISPOSE
I/A/W(SUPDAT)
| 1 | gloves_mandatory |
=======================================================
Product ID: 1700-001 SODIUM HYDROXIDE, VOLUMETRIC (SUPP DATA)
Cage: 78384
=======================================================
Contractor Summary
=======================================================
Cage: 78384
=======================================================
Ingredients
=======================================================
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: HARMFUL IF SWALLOWED, INHALED, OR ABSORBED THRU SKIN. MATL
IS EXTREMELY DESTRUCTIVE TO TISS OF MUCOUS MEMBRANES & UPPER RESP TRACK,
EYES & SKIN. INHAL MAY BE FATAL AS A RESULT OF SPASM, INFLAMM OF EDE MA
OF LARYNX AND BRONCHI, CHEM PNEUMONITIS & PULMONARY EDEMA. SYMP OF EXPOS
MAY INCL BURNING SENSATION (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:COUGHING, WHEEZING, LARYNGITIS,
SHORTNESS OF BREATH, HEADACHE, NAUSEA, AND VOMITING. TO THE BEST OF MFR
KNOWLEDGE, THE CHEMICAL PHYSICAL, AND TOXCIOLOGICAL PROPERTIES HAVE NOT BEEN
THOROUGHLY INVESTIGATED.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: SKIN/EYES:IMMED FLUSH EYES OR SKIN WITH COPIOUS AMOUNTS OF WATER FOR
AT LEAST 15 MINUTES WHILE REMOVING CONTAMINATED CLOTHING AND SHOES. ASSURE
ADEQUATE FLUSHING OF THE EYES BY SEPARATING EYELIDS WITH FINGERS.
INHAL:REMOVE TO FRESH AIR. IFNOT BREATHING GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. INGEST:CALL MD IMMEDIATELY (FP N).
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: EVACUATE AREA. WEAR SCBA, RUBBER BOOTS AND HEAVY
FOR DISPOSAL. VENTILATE AREA AND WASH SPILL SITE AFTER MATERIAL PICKUP IS C
OMPLETE.
Neutralizing Agent: BAKING SODA
Waste Disposal Methods: FOR SMALL QTYS:CAUTIOUSLY ADD TO LG STIRRED EXCESS OF
WATER. ADJUST PH TO NEUTRAL W/BAKING SODA, SEPARATE ANY INSOL SOLIDS OR LIQS
& PACKAGE FOR HAZ WASTE DISP. FLUSH AQUEOUS SOL DOWN DRAIN W/PLENTY O F
WATER. HYDROLYSIS NEUT RXNS MAY GEN HEAT(SUPDAT)
Handling And Storage Precautions: CORROSIVE. TOXIC. KEEP TIGHTLY CLOSED. STORE
IN COOL, DRY PLACE.
Other Precautions: DO NOT BREATH VAPOR. DO NOT GET IN EYES, ON SKIN, ON
CLOTHING. AVOID PROLONGED OR REPEATED EXPOSURE.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONE
Extinguishing Media: DRY CHEMICAL POWDER
Fire Fighting Procedures: NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
=======================================================
Control Measures
=======================================================
Respiratory Protection: WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation: NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment: PROTECTIVE CLOTHING. EMERG EYE WASH & DELUGE SHOWER
MEETING ANSI DESIGN CRITERIA (FP N).
Work Hygienic Practices: WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health: PARTNO/TRADE NAME:STANDARD, 1.0M SOLUTION IN
WATER. WASTE DISP METH:& FUMES WHICH CAN BE CONTROLLED BY RATE OF ADDN.
EYE PROT: LGTH FACESHIELD (FP N).
=======================================================
Physical/Chemical Properties
=======================================================
Vapor Pres: <18@20C
Vapor Density: <1
Spec Gravity: 1.040
Evaporation Rate & Reference: NOT KNOWN
Solubility in Water: NOT KNOWN
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: STRONG ACIDS
Hazardous Decomposition Products: NATURE OF DECOMPOSITION PRODUCT NOT KNOWN.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: 1700-001 SODIUM HYDROXIDE, VOLUMETRIC (SUPP DATA)
Cage: 78384
Company Name: LACHAT INSTRUMENTS
Street: 6645 WEST MILL ROAD
Zipcode: 53216
Label Required IND: Y
Date Of Label Review: 08/11/1994
Status Code: C
Label Date: 08/11/1994
Origination Code: G
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Severe
Contact Hazard: Severe
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: CORROSIVE. AVOID CONTACT AND EXPOSURE. ACUTE:HARMFUL IF
SWALLOWED, INHALED OR ABSORBED THROUGH SKIN. MATERIAL IS EXTREMELY
DESTRUCTIVE TO TISSUE OF MUCOUS MEMBRANES AND UPPER RESPIRATORY TRACT, EYES A
ND SKIN. INHAL:MAY BE FATAL. SYMPTOMS OF EXPOSURE MAY INCLUDE BURNING
SENSATION, COUGHING, WHEEZING, LARYNGITIS, SHORTNESS OF BREATH, HEADACHE,
NAUSEA AND VOMITING. CHRONIC:NONE LISTED BY MANUFACTURER .
=======================================================
| 1 | gloves_mandatory |
=======================================================
Product ID: GASKET REMOVER AEROSOL, 50020
Cage: ITWFL
=======================================================
Contractor Summary
=======================================================
Cage: 98148
Cage: ITWFL
=======================================================
Ingredients
=======================================================
Cas: 75-09-2
RTECS #: PA8050000
20C. LD50:(ORAL,RAT) 2000 MG/KG.
% Wt: 51-70
OSHA PEL: 500 PPM
ACGIH TLV: 50 PPM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 67-56-1
RTECS #: PC1400000
% Wt: 11-30
OSHA PEL: 200 PPM, S
ACGIH TLV: 200 PPM;250 STEL, S
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 74-98-6
RTECS #: TX2275000
% Wt: 11-30
OSHA PEL: 1000 PPM
ACGIH TLV: ASPHYXIANT
------------------------------
Cas: 75-28-5
RTECS #: TZ4300000
% Wt: 11-30
OSHA PEL: 1000 PPM (MFR)
ACGIH TLV: N/K (FP N)
------------------------------
RTECS #: 9999999VO
-----------------------------
PROCESSES OPERATING UNDER VACUUM IF
-----------------------------
UNDER ELEVATED PRESS IF SUDDEN ESCAPE OF
-----------------------------
ELEVATED-TEMP PROCESSES SHOULD BE THORO EVAL TO
-----------------------------
NO SMOKING IN AREA OF USE. DO NOT USE IN
-----------------------------
RADIA MAY CAUSE FORM OF HCL &/OR PHOSGENE (FP N).
-----------------------------
=======================================================
Health Hazards Data
=======================================================
=======================================================
Handling and Disposal
=======================================================
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: OC
Flash Point Text: -156F,-104C
Lower Limits: 1.8%
Upper Limits: 36.5%
Extinguishing Media: MEDIA SUITABLE FOR SURROUNDING FIRE (FP N).
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA &
FULL PROTECTIVE EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: THERMAL DECOMPOSITION PRODUCTS MAY INCLUDE HCL
& PHOSGENE (FP N).
=======================================================
Control Measures
=======================================================
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >10F,>-12C
Vapor Pres: SEE INGS
Vapor Density: >1
Spec Gravity: 1.13 (H*2O=1)
Evaporation Rate & Reference: >1 (BUTYL ACETATE=1)
Solubility in Water: INSOLUBLE
Appearance and Odor: COLORLESS TRANSPARENT LOW VISCOSITY LIQUID W/SWEET SOLVENT
ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEAT, SPARKS & OPEN FLAMES.
Materials To Avoid: WATER, ALKALIS, OXIDIZING AGENTS, POWDERED ALUMINUM & ZINC.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: GASKET REMOVER AEROSOL, 50020
Cage: ITWFL
Company Name: ITW FLUID PRODUCTS GROUP
Street: 8501 DELPORT DRIVE
Zipcode: 63114
Label Required IND: Y
Date Of Label Review: 07/24/1995
Status Code: C
Label Date: 07/24/1995
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE. ACUTE:INHALATION OF MIST OR VAPOR MAY
CONTRIBUTE TO THE OCCURRENCE OF IRREGULAR HEARTBEAT (FP N). EYES:SLIGHT TO
MODERATE IRRITATION. SKIN:SLIGHT TO MODERATE IRRITATION. INHAL:HIGH CONCENTR
ATIONS OF VAPORS MAY PRODUCE IRRITATIONOF RESPIRATORY TRACT, HEADACHE,
DIZZINESS & NAUSEA. MAY BE IRRITATING TO NOSE, THROAT & CHEST IF
MISTS ARE GENERATED IN USE. INGEST:SIMILAR TO INHALATION. SYMPTO MS:NAUSEA
& VOMITING. CHRONIC:CANCER HAZARD. CONTAINS METHYLENE CHLORIDE WHICHIS
LISTED AS AN ANIMAL LUNG & LIVER CARCINOGEN (FP N). PROLONGED REPEATED
OVEREXPOSURE TO THIS PRODUCT MAY LEAD TO SKIN SE NSITIZATION OR DERMATITIS.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PART A, 4501 PROTHANE WHITE-EXTREME HIGH (SUPDAT)
Kit Part:Y
Preparer's Name:E SOETERIK
CAGE:9D157
CAGE:9D157
============= Composition/Information on Ingredients =============
Ingred Name:ALIPHATIC POLYISOCYANATE CONTAINING ING 2,3,4 & 5
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ISOCYANIC ACID, HEXAMETHYLENE ESTER, POLYMERS; (HOMOPOLYMER
OF HDI 75%)
CAS:28182-81-2
RTECS #:NQ9170000
Fraction by Wt: 14.7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:XYLENE (SARA 313) (CERCLA)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 2.4%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHANOL, 2-ETHOXY-, ACETATE; (N-BUTYL ACETATE 12.5%)
CAS:111-15-9
RTECS #:KK8225000
Fraction by Wt: 2.4%
OSHA PEL:S, 100 PPM
ACGIH TLV:S, 5 PPM
Ingred Name:HEXANE, 1,6-DIISOCYANATO-; (HEXAMETHYLENE DIISOCYANATE)
(CERCLA)
CAS:822-06-0
RTECS #:MO1740000
OSHA PEL:N/K
ACGIH TLV:0.005 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SUPDAT:MARROW & BLOOD CELLS, KIDNEYS, LIVER & REPRO ORGANS.
CHRONIC EXPOS TO ISOCYANATES CAN CAUSE LUNG DMG. RPTS(ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:HAVE ASSOC RPTD & PRLNGD OCCUP OVEREXP TO SOLV CAN
CAUSE PERM BRAIN & NERV SYS DMG. INTENTIONAL MISUSE BY (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:DELIB CONC & INHAL CONTENTS MAY BE HARMFUL/FATAL. USE
ONLY W/ADEQ VENT.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:USING IN CONFINED AREA, USE AIR-FED HOOD.
RTECS #:9999999ZZ
Ingred Name:EYE PROT:SIDE SHIELDS
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:NAUSEA, DIZZINESS, HEADACHE, AND
CONVULSIONS. PROLONGED OR REPEATED EXPOSURE TO HIGH VAPOR
CONCENTRATIONS MAY RESULT IN CENTRAL NERVOUS SYSTEM DEPRESSION AND
NARCOSIS. SYMP OF OVEREXP:INHAL:VAP MAY BE IRRIT TO NOSE, EYES, &
RESP TRACT. OVEREXP CAN RSLT IN HDCH, NAUS & VOMIT. CONT W/SKIN OR
EYES: (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:BURNING SENSATION FROM VAPOR/LIQUID.
DERMATITIS, SENSITIZATION. ABSORB THRU SKIN:PRLNGD CONT W/SKIN MAY
LEAD TO ABSORP OF HARMFUL AMTS W/ACCOMPANYING SIGNS & SYMP OF TOX
AS DESCRIBED FOR SWAL LOWING. INGEST:TOX IF SWALLOWED. CAN CAUSE
BURNING SENSATION, VOMIT, DIARR, DROW. ASPIR OF VOMIT CAN CAUSE
PNEUM(SUPDAT)
Medical Cond Aggravated by Exposure:ASTHMA AND SKIN ALLERGIES. CAN
CAUSE DISCOMFORT TO PEOPLE W/THESE ALLERGIES, BUT NORMALLY IT IS
NOT A PROBLEM.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH IMMED W/FRESH WATER BY EYE WAS APPARATUS/BY HAND
FOR @ LEAST 15 MINS. SEEK MED ATTN. SKIN:WASH IMMED W/WATER. THEN
WASH W/SOAP & WATER, RINSE IMMED. SEEK MED ATTN. INHAL:MOVE PERSON
TO FRESH AIR; ARTF RESP IF NEC. SEEK MED ATTN. INGEST:SEEK MEDICAL
ATTENTION. DO NOT INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point:26.0F,-3.3C
Lower Limits:1.0%
Upper Limits:11.5%
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:NIOSH/MSHA APPRVD FULL FACE, SCBA & FULL PROT
EQUIP . BLANKET FLAME W/1 OF ABOVE. VAP OF COMBUST MAY BE IRRIT TO
RESP TRACT. MAY CAUSE BRTHG (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP MATERIAL AWAY FROM HEAT, SPARKS, AND
OPEN FLAMES.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL TYPES OF IGNITION SOURCES. PROVIDE
SUFFICIENT VENT. PROTECT CLEAN-UP PERSON W/8540 3MCORP RESP &
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT AGAINST PHYSICAL DMG TO CNTNRS
& SPILLAGE. STORE IN COOL WELL VENTILATED AREA W/SPRINKLER SYS.
KEEP AWAY FROM HEAT. POST NO SMOKING SIGNS.
Other Precautions:LABELING:RPTS HAVE SHOWN THAT ASSOC RPTD & PRLNGD
OCCUP OVEREXP TO SOLV CAN CAUSE PERM BRAIN & NERV SYS DMG.
INTENTIONAL MISUSE BY DELIB CONC & INHAL CONTENTS MAY BE
HARMFUL/FATAL. USE ONLY WITH ADEQU ATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPRVD DUST/MIST RESP (HIGH
EFFICIENCY CARTRIDGES ADVISED) IF SPRAYING/SANDING. USE NIOSH/MSHA
APPRD ORG VAP CARTRIDGE RESP IF TLF FOR SOLV COMPONENTS MAY BE
EXCEEDED E.G. 8540 3M CORPRESP, (NIOSH/MSHA APPRVD). WHEN (ING 9)
Ventilation:USE LOCAL EXHAUST WHEN APPLYING THIS PAINT IN CONFINED
AREAS. KEEP VAPORS BELOW TLV.
Other Protective Equipment:USE PROT CLTHG & CHANGE CONTAMD CLTHG IMMED.
ANSI APPRVD EMERGENCY EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:TRAIN EMPLOYEES ON ALL SPEC HNDLG PROC IN THIS
SECTION BEFORE THEY WORK W/THIS PRODUCT.
Supplemental Safety and Health
MFR TRADE NAME/PART NO:GLOSS LINEAR POLYURETHANE PAINT. FIRE FIGHT
PROC:DFCLTS. PVNT HUMAN EXPOS TO FIRE, SMOKE, FUMES, ETC. WEAR
PROD:C O*2, CO & POSS ACROLEIN. EFTS OF OVEREXP:& PULM EDEMA.
CHRONIC:RPTD EXPOS TO HIGH CONC MAY CAUSE INJURY TO BONE (ING 6)
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:175F,79C
Vapor Pres:18.73 @20C
Vapor Density:3.81
Spec Gravity:1.29
Evaporation Rate & Reference:1.74 (BUTYL ACETATE =1)
Solubility in Water:PARTIAL
Appearance and Odor:WHITE OR COLORED LIQUID WITH STRONG SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, AMINES, STRONG BASES, ALCOHOLS, METAL CMPDS & SURFACE ACTIVE
MATERIALS.
Stability Condition to Avoid:HEAT, SPARKS & OPEN FLAMES. DO NOT ALLOW
VAP TO ACCUMULATE.
Hazardous Decomposition Products:FLAM FUMES MAY ACCUMULATE IN CONFINED
AREA & SPARKS OR OPEN FLAMES MAY IGNITE IT. MAY LIBERATE SMOKE,
FUMES, (SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:USE METAL CNTNR MARKED "DO NOT REUSE". PUT MATL
IN THIS CNTNR. USE VERMICULITE/OTHER INERT ABSORB. KEEP AWAY FROM
SEWER. NOTE:DISPOSE OF ALL WASTES I/A/W FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:75685-00213,BERMUDA BLUE, RED DEVIL GLOSS (SUP DAT)
CAGE:THOMP
CAGE:63272
CAGE:THOMP
============= Composition/Information on Ingredients =============
Ingred Name:C.I. PIGMENT RED 49; (BARIUM LITHOL RED) %: 0.01-6.78
CAS:1103-38-4
Fraction by Wt: <6.78%
OSHA PEL:0.5 MG/M3 (MFR)
ACGIH TLV:0.5 MG/M3 (MFR)
Ingred Name:NAPHTHA, HEAVY STRAIGHT RUN; (NAPHTHA (PETROLEUM), HEAVY
STRAIGHT-RUN)
CAS:64741-41-9
Fraction by Wt: 1-2%
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC
CAS:64742-88-7
Fraction by Wt: 12-35%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 5-15%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE) %: 0.0001-25.0
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: <25%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:VOLATILE ORGANIC COMPOUND: 450 G/L MAXIMUM
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: AVOID PROLONGED
BREATHING OF VAPOR OR SPRAY MIST. SKIN/EYES/INGESTION: NONE
EXPECTED. CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PREEXISTING LUNG DISORDERS MAY BE
AGGRAVATED BY INHALATION DURING USE.
======================= First Aid Measures =======================
First Aid:INHALATION: IF BREATHING IS AFFECTED, IMMEDIATELY MOVE TO
FRESH AIR. SKIN: IN KEEPING WITH GOOD HYGIENIC PRACTICES, WASH
THOROUGHLY WITH SOAP AND WATER. IF IRRITATION PERSISTS, CONTACT MD.
EYES: AS IN THE CASE WHEN ANY FOREIGN MATTER CONTACT THE EYE,
RINSE THOROUGHLY WITH WATER. INGESTION: CONTACT MD OR A POISON
CONTROL CENTER.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:104F,40C
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEM/CARBON DIOXIDE. DO NOT
USE DIRECT STREAM OF WATER. PROD WILL FLOAT & CAN BE (SUP DAT)
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . COMBUSTIBLE. USE WATER SPRAY TO COOL FIRE-EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:COMBUST. CONTAINS PETRO DISTILS. KEEP
AWAY FROM HEAT & FLAME. CONTRS EXPOSED TO INTENSE HEAT FROM FIRES
SHOULD BE COOLED W/WATER TO PVNT VAP PRESS (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SMALL SPILLS W/SAND/OTHER SUITABLE
ABSORB MATL & PLACE IN CONTR FOR DISP. FOR LARGE SPILLS, AREA MAY
BE SLIPPERY, DIKE AROUND SPILL W/ABSORB MATL. TRANSFER LIQS &
CONTAM DIKING MATL TO SEPARATE , SUITABLE CONTRS FOR
RECOVERY/DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:COMBUSTIBLE. CONTAINS PETROLEUM
DISTILLATES. AVOID PROLONGED BREATHING OF VAPOR. KEEP OUT OF REACH
OF CHILDREN.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID PROLONGED BREATHING OF VAPOR. USE NIOSH
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE REQUIRED.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
TRADE NAME/PART #:POLYURETHANE OIL ENAMEL-NAT VOC-ALL SHADES. % VOLAT:
53.3-70.1. EXTING MEDIA: REIGNITED ON SURF OF WATER. EXPLO HAZ:
BUILD-UP WHICH COULD RSLT IN CONTR RUPTURE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:220F,104C
Vapor Pres:<55 @ 20C
Vapor Density:4.8
Spec Gravity:0.94-1.32
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORED, VISCOUS LIQUID WITH PETROLEUM SOLVENT ODOR
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, ALL SOURCES OF
HEAT OR IGNITION.
Hazardous Decomposition Products:HYDROCARBON FUMES, SMOKE, CARBON
MONOXIDE (WHERE COMBUSTION IS INCOMPLETE) MAY BE FORMED DURING
THERMAL DECOMPOSITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DERUSTO,861 GLOSS LT YELLOW,ENAMEL,AEROSOL
CAGE:1BL51
CAGE:1BL51
CAGE:90300
============= Composition/Information on Ingredients =============
Ingred Name:METHYLENE CHLORIDE(SARA III)
CAS:75-09-2
RTECS #:PA8050000
OSHA PEL:500 PPM/C,1000; Z2
ACGIH TLV:50 PPM, A2; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 1-30%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:NAPHTHA (PETROLEUM SPIRITS OR BENZIN)
CAS:8030-30-6
RTECS #:SE7555000
Fraction by Wt: 1-25%
OSHA PEL:100 PPM
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 0-10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:ZINC CHROMATE
CAS:13530-65-9
RTECS #:GB3290000
Fraction by Wt: 0-3%
OSHA PEL:0.1 MG/M3 (CRO3)
ACGIH TLV:0.01MG/M3(CR)A1;9192
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:A NUMBER OF STUDIES SUPPLIED BY MFR'S
TRADE ASSOC HAS INDICATED THAT CONTINUAL OVEREXPOS TO CONC SOLVENT
VAP OVER A PERIOD OF TIME MAY LEAD TO PERMANENT CNS DAMAGE.
METHYLENE CHLORIDE HAS BEEN IDENTIF IED AS AN ANIMAL CARCINOGEN BY
NTP,BUT IS NOT ON THE IARC,OSHA CARCINOGEN LISTS
Effects of Overexposure:ACUTE:LIQUID & VAPOR IRRITATES EYES,SKIN &
RESPIRATORY TRACT. MAY CAUSE CENTRAL NERVOUS SYSTEM
DEPRESSION:HEADACHE,DIZZINESS,FATIGUE,NAUSEA OR UNCONSCIOUSNESS. IF
INGESTED CAUSEAS NAUSEA,VOMITING,DIAR RHEA,DEPRESSED RESPIRATION.
CHRONIC:LIQUID MAY CAUSE DERMATITIS AFTER PROLONGED OR REPEATED
EXPOSURE TO SKIN.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN
DISORDERS,IMPAIRED PULMONARY FUNCTIONS,LIVER & KIDNEY DISORDERS &
CARDIOVASCULAR CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR:RESTORE BREATHING IF NECESSARY.CALL
PHYS.EYE:FLUSH W/LRG AMTS OF H*20 FOR 15 MIN.CALL PHYS.SKIN:WASH
W/SOAP&H*20.CONSULT PHYS IF IRRITATION DEVELOPS.INGEST:DO NOT
INDUCE VOMI TING.IF CONSCIOUS,GIVE H*20/MILK.CALL PHYS IMMED.
===================== Fire Fighting Measures =====================
Flash Point:AEROSOL
Extinguishing Media:FOAM,CARBON DIOXIDE,OR DRY CHEMICALS
Fire Fighting Procedures:DO NOT USE STRAIGHT HOSE WATER STREAM.FULL
PROTECTIVE EQUIPMENT,INCLUDING SCBA,IS RECOMMENDED TO PROTECT FROM
COMBUSTION PRODUCTS.COOL EXPOSED CONTAINERS W/H*2O
Unusual Fire/Explosion Hazard:CNTNR MAY EXPLODE W/EXPOS TO EXTREME
HEAT;KEEP FROM HEAT,ELEC EQUIP,SPARKS,OPEN FLAME.DONT PUT IN CONT
W/OXIDIZING MATLS.POSS THERMAL DECOMP PRODS:HCL,PHOSGENE.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL:USE ABSORB MATL/SCRAPE UP DRIED MATL,PUT
IN CNTNR.LRG:WEAR PROT EQUIP.ELIM IGNITN SOURCE ,VENT AREA.DIKE TO
PREV SPREAD.USE ABSORB MATL,PUT IN CNTNR.CLEANUP REMAINDR
W/NONFLAMM SOLVNT LIKE IIITR ICHLOROETHANE (MFR).PREV RUNOFF TO
BODIES OF H*20.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNR FROM HEAT,FLAME,DIRECT
SUN.DONT STORE @>120F.PROVIDE CROSS VENT WHERE STORE.KEEP CNTNR
CLOSED TIGHT WHEN NOT USING.HARMFUL/FATAL IF SWALLOW
Other Precautions:CNTNS FLAMM SOLVENT.VAP HARMFUL,POSS FLASH
FIRE.CONTNTS UNDER PRESS:DONT PUNC/INCINER CNTNR.USE W/ADEQ
VENT,ELIM IGNITN SOURCE.AVOID PRLNG/RPTD SOLVENT VAP INHAL,SKIN
CONT.WASH CONTAM CLOTHES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD RESPIRATR IF EXCEED EXPOS
LIMIT.SEE 29CFR 1910.134
Ventilation:SUFFICIENT MECH (LOCAL/GENERAL EXHAUST)-KEEP EXPOS
<PEL,TLV.
Other Protective Equipment:EYEWASH,SOLVENT IMPERV APRON,BARRIER
Supplemental Safety and Health
METHYLENE CHLORIDE-ACGIH NOTICE OF INTENDED CHANGES FOR
1986-87);PROPANE-ISOBUTANE PROPELLANT,20-30%,(ACCORDING TO
ACGIH,PROPANE IS A SIMPLE ASPHYXIANT),OSHA PEL-(PROPANE) 1000PPM.
ACCORDING TO MFR,FO LLOWING INGREDIENTS ARE NONHAZARDOUS:SOYA ALKYD
RESIN,PIGMENTS,INERT ADDITIVES.
================== Physical/Chemical Properties ==================
Vapor Pres:530 @ 30F
Vapor Density:3.32
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OPAQUE LIQUID,LT YELLOW COLOR GASOLINE-LIKE ODOR
Percent Volatiles by Volume:75-85
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS & CAUSTICS
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:NORMAL COMBUSTION PRODUCTS,I.E.
CO*X,NO*X; HCL,PHOSGENE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARDED SPILL RESIDUE MAY BE INCINERATED. DO
NOT INCINERATE SEALED CONTAINERS. DISPOSE ACCORDING TO
FEDERAL,STATE & LOCAL REGULATIONS. LIQUIDS CANNOT BE DISPOSED OF IN
A LANDFILL.
| 1 | gloves_mandatory |
=======================================================
Product ID: FRESH GEL DEODORANT - CHERRY
Cage: 0LDP3
Box: 3484
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 0LDP3
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: MODERATE IRRITATION OF SKIN OR EYES. EXCESSIVE INHALATION
OF VAPORS CAN CAUSE NASAL & RESPIRATORY IRRITATION, DIZZINESS, NAUSEA,
HEADACHE, POSSIBLE UNCONSCIOUSNESS OR ASPHYXIATION. SWALLOWING CAN CAUS E
GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING & DIARRHEA.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: IRRITATION OF SKIN OR EYES, RESPIRATORY OR
GASTROINTESTINAL TRACT, DIZZINESS, NAUSEA, HEADACHE, VOMITING OR DIARRHEA.
Medical Cond Aggravated By Exposure: PRE-EXISTING SKIN OR LUNG DISORDERS.
First Aid: EYES:FLUSH W/WATER FOR AT LEAST 15 MINUTES. SKIN:WASH W/SOAP &
WATER. INHAL:MOVE VICTIM TO FRESH AIR. INGEST:DO NOT INDUCE VOMITING. IN ALL
CASES WHERE PAIN IN AN AFFECTED AREA PERSISTS, CALL MD.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION. VENTILATE SPILL AREA.
SOAK UP ON ABSORBENT MATERIAL. PUT INTO CLOSED CONTAINER. KEEP MATERIAL OUT
OF DRAINS, SEWERS OR OPEN WATER-WAYS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: USE IN FIXTURE & DISPOSE OF CONTAINER ACCORDING TO
LOCAL, STATE &/OR FEDERAL LAWS.
Handling And Storage Precautions: STORE AWAY FROM HEAT & OPEN FLAME. AVOID
CONTACT W/SKIN & EYES.
Other Precautions: THIS PRODUCT MUST BE KEPT OUT OF THE REACH OF CHILDREN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: 117F,47C
Extinguishing Media: FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: DO NOT EXPOSE TO HIGH TEMPERATURES OR OPEN
FLAMES.
=======================================================
Control Measures
=======================================================
Respiratory Protection: WHEN CONCENTRATION EXCEEDS RECOMMENDED LIMITS, USE
NIOSH/MSHA APPROVED RESPIRATOR W/ORGANIC VAPOR CARTRIDGES.
Ventilation: MECHANICAL (GENERAL): SUFFICIENT TO MAINTAIN VAPORS BELOW TLV.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: WASH HANDS AFTER HANDLING.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 360F,182C
Vapor Pres: <1 PSIG
Spec Gravity: 0.89 (H*2O=1)
Solubility in Water: INSOLUBLE
Appearance and Odor: GEL COLORED TO MATCH FRAGRANCE; CHERRY ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HIGH HEAT OR FLAME.
Materials To Avoid: STRONG OXIDIZING AGENTS, STRONG ACIDS OR ALKALIES.
Hazardous Decomposition Products: PRODUCTS OF COMBUSTION MAY INCLUDE CARBON
MONOXIDE & CARBON DIOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: LABEL COVERED UNDER EPA REGS - HAZCOM LABEL NOT AUTHORIZED
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LEVELAYER PRIMER (J-42)
Preparer's Name:ROBERT L. JONES
CAGE:DAYTO
CAGE:DAYTO
============= Composition/Information on Ingredients =============
Ingred Name:ACETIC ACID ETHENYL ESTER POLYMER WITH ETHENE; (VINYL
ACETATE/ETHYLENE COPOLYMER)
CAS:24937-78-8
Fraction by Wt: 45-55%
OSHA PEL:N/K
ACGIH TLV:10 PPM
Ingred Name:FORMALDEHYDE (SARA 302/313) (CERCLA)
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: <0.1%
OSHA PEL:N/K
ACGIH TLV:0.3 PPM, C
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:SPILL PROC: CHLORIDE AND LIME. DECANT WATER. DISPOSE OF
SOLIDS IN LANDFILL.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: CAN CAUSE IRRIT OF NASAL TRACT.
MAY PROVOKE ASTHMATIC RESPONSE IN PERS W/ASTHMA WHO ARE SENSITIVE
TO AIRWAY IRRITANTS. SKIN CNTCT: CAN CAUSE REDNESS, IRRRIT &
DRYNESS. EYE CNTCT: CAN CAUSE REDN ESS, IRRIT. INGEST: NO KNOWN
SYMPS. FORMALDEHYDE CAN CAUSE NASAL CANCER IN LAB ANIMALS, HOWEVER
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: OBJECTIVE DATA INDICATE UNDER TYPICAL
CNDTNS OF USE FOR PROD, TWA/TLV WILL NOT BE EXCEEDED. ODOR
DETECTION LEVEL VARIES AMONG DIFFERENT INDIVIDUALS BETWEEN 0.2 TO 1
PPM. PROD ALSO CNTNS SM A MTS OF VINYL ACETATE, VAPS OF WHICH HAVE
BEEN SHOWN TO CAUSE TUMORS OF RESP TRACT OF LAB ANIMALS. THERE IS
NO (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: MOVE SUBJECT TO FRESH AIR. IF BRTHG DFCLTY DEVELOPS,
ADMIN OXYGEN. CALL MD. SKIN: WASH AFFECTED AREAS W/SOAP & WATER. IF
IRRIT PERSISTS, SEEK MED ATTN. REMOVE CONTAMD CLTHG & THORO CLEAN &
DRY BEFORE REUSE. EYES: FLUSH W/LG AMT OF WATER FOR AT LEAST 15
MIN WHILE LIFTING UPPER & LOWER EYELIDS. IF IRRIT PERSISTS, SEEK
MED ATTN. INGEST: SMALL INGESTED AMTS ARE NOT BELIEVED TO PRDCE
(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . CARBON DIOXIDE, WATER SPRAY.
Unusual Fire/Explosion Hazard:NO UNUSUAL FIRE OR EXPLOSION HAZARDS.
================== Accidental Release Measures ==================
Spill Release Procedures:DAM MATL TO LIMIT SPREADING. MOP UP OR ABSORB
ON INERT MATL & PLACE IN CNTNR. IF SPILL OCCURS IN ENCLSD AREA,
VENT AREA. SPILLED EMULSION IS VERY SLIPPERY. USE CARE TO AVOID
FALLS. FOR LG QTY SPILLS, PLACE IN SETTLING POND & ADD FERRIC (ING
3)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE AND KEEP
FROM FREEZING. PRODUCT MAY COAGULATE.
Other Precautions:MINIMIZE CONTACT WITH AIR TO PREVENT INNOCULATION
WITH MICROORGANISMS WHICH CAN CAUSE DECOMPOSITION AND MOLDY
OVERGROWTH.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED IF GOOD VENTILATION IS MAINTAINED;
OTHERWISE, WEAR NIOSH/MSHA APPROVED SELF-CONTAINED BREATHING
APPARATUS (PRESSURE DEMAND).
Ventilation:MECHANICAL LOCAL EXHAUST VENTILATION AT POINT OF
CONTAMINANT RELEASE.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
% VOLAT: 45-55 (BY WT). EFTS OF OVEREXP: EVID IT HAS CAUSED CANCER IN
HUMANS. PROD CNTNS TRACE OF FORMALDEHYDE, LISTED BY STATE OF CA
(PROP 65) AS CHEM KNOWN TO CAUSE CANCER. FIRST AID PROC: ADVERSE H
LTH EFTS. LARGER AMTS (SEVERAL OUNCES) SHOULD BE REMOVED FROM STOM
BY INDUCING VOMIT OR ASPIR. CALL MD.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:WATER
Vapor Density:WATER
Spec Gravity:1.0-1.1(H*2O=1)
pH:4-7
Solubility in Water:MISCIBLE
Appearance and Odor:PINK LIQUID; PLEASANT, SWEET ODOR.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SULFURIC ACID, ALKALI MATERIALS (I.E., SODIUM OR METAL HYDRIDES).
Stability Condition to Avoid:FREEZING.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
ACETIC ACID, ACETALDEHYDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISP MUST BE I/A/W FED, STATE & LOCAL REGS .
COAGULATE DILUTED EMULSION BY SLOW ADDN OF FERRIC CHLORIDE & LIME,
MAINTAINING PH OF 8. SETTLED SLUDGE CAN BE DISPOSED OF IN APPRVD
LANDFILL SITES. E MULSION CAN BE INCIN DIRECTLY UNDER APPROP
CNDTNS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FA5254
CAGE:JO774
CAGE:81831
CAGE:JO774
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMED.SKIN:WASH W/SOAP IMMED.INHAL:REMOVE
TO FRESH AIR.GIVE ART.RESPIR. AS NEEDED.INGEST:GET MEDICAL
ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE VOMITING,BUT DO NOT MAKE
UNCONSCIOUS PE RSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS.CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE,THROAT.
================== Physical/Chemical Properties ==================
HCC:V1
Appearance and Odor:LIGHT STRAW COLORED LIQUID,AROMATIC ODOR.
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1824-411
Preparer's Name:ILLEGIBLE ON MSDS
CAGE:0AP29
CAGE:0AP29
CAGE:07XT7
============= Composition/Information on Ingredients =============
Ingred Name:2-ETHOXYETHANOL (SARA 313) (CERCLA)
CAS:110-80-5
RTECS #:KK8050000
Fraction by Wt: 11%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S, 200 PPM
ACGIH TLV:S, 5 PPM; 9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PHOSPHORIC ACID (SARA 313) (CERCLA)
CAS:7664-38-2
RTECS #:TB6300000
Fraction by Wt: 71%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3/3 STEL; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:**CORROSIVE88 EYES:MAY CAUSE
IRRITATION.SKIN:MAY CAUSE IRRITATION.INGEST:ASPIRATION HAZARD.MAY
CAUSE GI TRACT IRRITATION.INHAL:MAY CAUSE RESPIRATORY IRRITATION
AND CNS EFFECTS
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of Overexposure:EYES:BLURRED
VISION.INHAL:HEADACHES,DIZZINESS,ANESTHESIA.SKIN:BURNS,DERMATITIS.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
CONDITIONS MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH SOAP AND
WATER.GET MEDICAL ATTENTION IF NEEDED.EYES:FLUSH WITH WATER FOR 15
MINUTES.GET IMMEDIATE MEDICAL ATTENTION.INHAL:REMOVE TO FRESH
AIR.GIVE OXYGEN ORARTIFICIAL RESPIRATION IF NEEDED.GET IMMEDIATE
MEDICAL ATTENTION.INGEST:DO NOT INDUCE VOMITING.GET PROMPT
QUALIFIED MEDICAL ATTENTION.IF CONSCIOUS,GIVE SEVERAL GLASSES OF
WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Extinguishing Media:DRY CHEMICAL,CARBON DIOXIDE,TYPE BC/ABC
EXTINGUISHERS.
Fire Fighting Procedures:HMIS SUGGESTS TO USE A SELF-CONTAINED
BREATHING APPARATUS WHENEVER FIGHTING A CHEMICAL FIRE.
Unusual Fire/Explosion Hazard:MANUFACTURER STATES NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP WITH NON-COMBUSTIBLE INERT
ADSORBANT(EG.CLAY);PLACE COLLECTED MATERIAL IN AN APPROPRIATE
CONTAINER FOR DISPOSAL;CLEAN SPILL AREA TO REMOVE SLIPPERINESS.FOR
SMALL SPILLS,USE AN INDUSTRIAL SEWER .
Neutralizing Agent:NOT REPORTED.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY,WELL-VENTILATED
PLACE.KEEP CONTAINER CLOSED WHEN NOT IN USE.KEEP AWAY FROM
INCOMPATIBLE MATERIALS.
Other Precautions:FOLLOW LABEL DIRECTIONS.AVOID BREATHING VAPORS.AVOID
SKIN AND EYE CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NEEDED IN NORMAL SERVICE.
Ventilation:LOCAL VENTILATION AT THE WORKSITE;MECHANICAL(GENERAL)
VENTILATION TO MAINTAIN TLV/PEL.
Other Protective Equipment:PROTECTIVE CLOTHING,AS NEEDED.PROVIDE A
LOCAL EYE WASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:EXECISE GOOD LABORATORY PRACTICES.WASH HANDS
AFTER USE AND BEFORE EATING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:=100.C, 212.F
Spec Gravity:1.612
pH:>1
VOC Grams/Liter:1.8
Viscosity:2.3 CPS
Evaporation Rate & Reference:1.2 WATER=1
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID;WATER WHITE;ACIDIC ODOR.
Percent Volatiles by Volume:90
Corrosion Rate:CORROSIV
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALI,REDUCING AND OXIDIZING AGENTS,ALUMINUM FINES(DUST).
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE,CARBON MONOXIDE,OXIDES
OF PHOSPHOROUS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.
======================================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BWT-13
Preparer's Name:RUSS LARSEN
CAGE:7Z399
CAGE:7Z399
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM SULFITE
CAS:7757-83-7
RTECS #:WE2150000
Fraction by Wt: 10-20%
Other REC Limits:5 MG/CUM (DUST)
Ingred Name:SODIUM LIGNOSULFONATE
CAS:8061-51-6
RTECS #:OI6174000
Fraction by Wt: <5%
ACGIH TLV:NONE
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN/INGESTION: IRRITANT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: BURNING, REDNESS. SKIN: RASH, REDNESS.
INGESTION: NAUSEA, VOMITING.
Medical Cond Aggravated by Exposure:ASTHMATICS ARE GENERALLY SENSITIVE
TO SODIUM SULFITE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MIN. SKIN: WASH OFF THOROUGHLY
W/SOAP & WATER. INGESTION: GIVE WATER TO DILUTE. CALL A PHYSICIAN.
CERTAIN INDIVIDUALS ARE SENSITIVE TO SODIUM SULFITE. OBTAIN MEDICAL
ATTENTI ON IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, FOAM, CO2 & DRY CHEMICAL.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL. ABSORB ON INERT MATERIAL &
SHOVEL INTO A SUITABLE CONTAINER. HOLD FOR PROPER DISPOSAL. CONTACT
LOCAL AUTHORITIES FOR ADVICE.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT.
============= Exposure Controls/Personal Protection =============
Other Protective Equipment:EYE WASH
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. USE GOOD SAFE PRACTICE & PERSONAL HYGIENE WHEN USING THIS
PRODUCT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text: 100C
Melt/Freeze Pt:M.P/F.P Text: 30F
Vapor Pres:AS WATER
Spec Gravity:1.09
pH:9-10
Evaporation Rate & Reference:(BU AC = 1): <1
Appearance and Odor:BROWN LIQUID, ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS & STRONG ACIDS.
Hazardous Decomposition Products:SO2 BY REACTION W/ACIDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:METHYL ALCOHOL 14280, A4544LOT012
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ALCOHOL; (METHANOL) (SARA 313) (CERCLA)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: >99%
OSHA PEL:S, 200 PPM
ACGIH TLV:S,200PPM/250STEL; 95
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SUPDAT: SUBSTANCE IS ALSO INCOMPATIBLE W/SPECIFIC CHEMS
INCL: ACETYL BROMIDE, ALKYL ALUMINUM SALTS, BERYLLIUM (ING 3)
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ING 2: DIHYDRIDE, CARBON TETRACHLORIDE + METALS, CHLOROFORM
+ HEAT, CHLOROFORM + SODIUM HYDROXIDE, CYANURIC (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3: CHLORIDE, DIETHYL ZINC, NITRIC ACID, AND POTASSIUM
TERTBUTOXIDE. PLEASE REFER TO THE NFPA FIRE PROTECTION (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: GUIDE FOR ALL SPECIFICS.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP: MAY CAUSE EFTS SIMILAR TO THOSE DESCRIBED
FOR INGEST. CHRONIC: PRLNG/RPTD SKIN CNTCT MAY CAUSE (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: DERMATITIS. CHRONIC INHALATION & INGESTION MAY CAUSE
EFFECTS SIMILAR TO THOSE OF ACUTE INHALATION & INGESTION.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: GIVING ONE TEASPOON OF SYRUP OF IPACAC.
INHAL: GET MED AID IMMED. REMOVE FROM EXPOS TO FRESH AIR (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: IMMED. IF NOT BRTHG, GIVE ARTF RESP. IF BRTHG IS
DFCLT, GIVE OXYGEN. NOTES TO MD: EFTS MAY BE DELAYED. (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: ETHANOL MAY INHIBIT METABOLISM. ANTIDOTE: NO
SPECIFIC ANTIDOTE EXISTS.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: NON-COMBUSTIBLE MATERIAL SUCH AS EARTH, SAND,
OR VERMICULITE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT): 5628 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: CAUSES MOD EYE IRRIT.
VAPS MAY CAUSE EYE IRRIT. MAY CAUSE PAINFUL SENSIT TO LIGHT. SKIN:
MAY CAUSE SKIN IRRIT. MAY BE ABSORBED THRU SKIN IN HARMFUL AMTS.
INGEST: MAY CAUSE IRRIT OF DIGEST TRACT. MAY CAUSE CNS DEPRESS,
CHARACT BY EXCITEMENT, FOLLOWED BY HDCH, DIZZ, DROW, & NAUS. (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: ADVANCED STAGES MAY CAUSE COLLAPSE,
UNCONSCIOUSNESS, COMA & POSS DEATH DUE TO RESP FAILURE. MAY CAUSE
KIDNEY FAILURE. INHAL: MAY CAUSE RESP TRACT IRRIT. MAY CAUSE LIVER
& KIDNEY DMG. MAY CAU SE ADVERSE CNS EFTS INCL HDCH, CONVULSIONS, &
POSS DEATH. MAY CAUSE VISUAL IMPAIRMENT & POSS PERM BLINDNESS. (ING
6)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF H*2O FOR AT LEAST 15 MIN, OCCAS
LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. DO NOT ALLOW VICTIM
TO RUB/KEEP EYES CLSD. SKIN: FLUSH W/PLENTY OF SOAP & H*2O FOR AT
LEAST 15 MI N WHILE REMOVING CONTAMD CLTHG & SHOES.GET MED AID IF
IRRIT DEVELOPS/PERSISTS. INGEST: IF VICTIM IS CONSCIOUS & ALERT,
GIVE 2-4 CUPFULS OF MILK/H*2O. GET MED AID IMMED. INDUCE VOMIT BY
(ING 8)
===================== Fire Fighting Measures =====================
Flash Point:53.6F,12.0C
Lower Limits:6.00 VOL %
Upper Limits:31.00 VOL %
Extinguishing Media:FOR SMALL FIRES, USE DRY CHEM, CARBON DIOXIDE,
WATER SPRAY/ALCOHOL-RESISTANT FOAM. USE WATER SPRAY TO COOL
(SUPDAT)
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
CNTNRS CAN BUILD UP PRESS IF EXPOSED TO HEAT &/FIRE. VAPS CAN
TRAVEL TO A SOURCE OF IGNIT & FLASH BACK. (SUPDAT)
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:GENERAL INFO: USE PROPER PERS PROT EQUIP AS
INDICATED IN SECTION 8. SCOOP UP W/NONSPARKING TOOL, THEN PLACE
INTO A SUITABLE CNTNR FOR DISP. USE WATER SPRAY TO DISPERSE
GAS/VAP. REMOVE ALL SOURCES OF I GNIT. ABSORB SPILL USING AN
ABSORBENT, (ING 11)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM SOURCES OF IGNITION.
STORE IN A COOL, DRY, WELL-VENTD AREA AWAY FROM INCOMPATIBLE
SUBSTANCES. FLAMMABLES-AREA. USE W/ADEQUATE VENT.
Other Precautions:EMPTY CNTNRS RETAIN PROD RESIDUE, (LIQ &/VAP), & CAN
BE DANGEROUS. DO NOT GET ON SKIN/IN EYES. DO NOT INGEST/INHALE. DO
NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL, GRIND/EXPOSE EMPTY
CNTNRS TO HE AT, SPARKS OR OPEN FLAMES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATORY REGULATIONS FOUND IN
29CFR 1910.134. ALWAYS USE A NIOSH-APPROVED RESPIRATOR WHEN
NECESSARY.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENT TO KEEP AIRBORNE
CONCENTRATIONS BELOW THE PERMISSIBLE EXPOSURE LIMITS.
Other Protective Equipment:ANSI APPRVD EMER EYE WASH & DELUGE SHOWER .
WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
Supplemental Safety and Health
EXTING MEDIA: FIRE-EXPOSED CNTNRS. H*2O MAY BE INEFT. FIRE FIGHT PROC:
DURING A FIRE, IRRIT & HIGHLY TOX GASES MAY BE GENERATED BY THERMAL
DECOMP/COMBUST. FLAMM LIQ. CAN RELS VAPS THAT FORM EXPLO MIXT AT
TEMPS ABOVE FLASHPOINT. MATL TO AVOID: SODIUM HYPOCHLORITE), ACTIVE
METALS (SUCH AS POTASSIUM & MAGNESIUM). (ING 2)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:148F,65C
Melt/Freeze Pt:M.P/F.P Text:-144F,-98C
Vapor Pres:96
Vapor Density:1.1
Spec Gravity:0.791
Evaporation Rate & Reference:5.2 (ETHER = 1)
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID; SLIGHT ALCOHOL-LIKE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDANTS (SUCH AS BARIUM PERCHLORATE, BROMINE, CHLORINE, HYDROGEN
PEROXIDE, LEAD PERCHLORATE, PERCHLORIC ACID, (SUPDAT)
Stability Condition to Avoid:HIGH TEMPERATURES, INCOMPATIBLE MATERIALS,
IGNITION SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
FORMALDEHYDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE, AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PROSEAL 870 C-12, PT B
Preparer's Name:LR
CAGE:DO563
CAGE:83574
CAGE:DO563
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Other REC Limits:100 PPM
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PHENOLIC RESIN
CAS:9003-35-4
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITANT. MAY CAUSE
ALLERGIC SKIN RASH IN SENSITIZED INDIVIDUALS. INHALATION: MAY CAUSE
NAUSEA, VOMITING, ANESTHESIA, DIZZINESS, HEADACHE & RESPIRATORY
IRRITATION. INGESTION: MAY CAUSE ABDO MINAL PAIN, LIVER & KIDNEY
DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN/EYES: IRRITANT. MAY CAUSE ALLERGIC SKIN
RASH IN SENSITIZED INDIVIDUALS. INHALATION: MAY CAUSE NAUSEA,
VOMITING, ANESTHESIA, DIZZINESS, HEADACHE & RESPIRATORY IRRITATION.
INGESTION: MAY CAUSE ABDO MINAL PAIN, LIVER & KIDNEY DAMAGE.
Medical Cond Aggravated by Exposure:ALLERGIC SKIN RASH.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LUKE WARM WATER FOR 15 MINS. IF SYMPTOMS
PERSIST, CONSULT PHYSICIAN. SKIN: WASH WITH SOAP & WATER. IF
SYMPTOMS PERSISTS, CONSULT PHYSICIAN. INHALATION: REMOVE TO FRESH
AIR. IF SYMPTOMS A RE PRESENT CONSULT PHYSICIAN. INGESTION: INDUCE
VOMITING, CONSULT PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:>200F
Lower Limits:1.0%
Upper Limits:7.0%
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER
Fire Fighting Procedures:USE AIR SUPPLIED RESPIRATOR
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. SCOOP INTO
CONTAINERS. CLEAN-UP RESIDUE WITH 1,1,1-TRICHLOROETHANE.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Ventilation:PROVIDE LOCAL EXHAUST VENTILATION TO KEEP <TLV
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Density:3.2
Spec Gravity:1.43
Evaporation Rate & Reference:(TOLUENE): 2
Solubility in Water:NEGLIGIBLE
Percent Volatiles by Volume:8.5%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS
Hazardous Decomposition Products:OXIDES OF CARBON, SO2, TRACES OF H2S.
==================== Disposal Considerations ====================
Waste Disposal Methods:EPA WASTE NO. D-001. DISPOSE OF SPILLAGE IN
COMPLIANCE WITH FEDERAL AND STATE REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ACTIVATED ALUMINA, F-200
CAGE:8B997
CAGE:8B997
CAGE:28193
============= Composition/Information on Ingredients =============
Ingred Name:ALPHA-ALUMINA (ALUMINUM OXIDE) (SARA III)
CAS:1344-28-1
RTECS #:BD1200000
Fraction by Wt: 90-95%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9394
Ingred Name:SODIUM MONOXIDE
CAS:12401-86-4
RTECS #:WC4800000
Fraction by Wt: 0.3-0.6%
Ingred Name:SILICON DIOXIDE (AMORPHOUS)
Fraction by Wt: 0.1-.2%
Other REC Limits:NONE RECOMMENDED
Ingred Name:IRON OXIDE
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: .03-.1%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5MG/M3(FE)FUME,B2;94
Ingred Name:LOSS ON IGNITION (WATER)
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 4.0-7.0%
===================== Hazards Identification =====================
LD50 LC50 Mixture:MFR GAVE NO INFORMATION ON MSDS.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THE DESICCANT PROPERTIES OF ALCOA
ACTIVATED ALUMINA MAY CAUSE IRRITATION TO EYES & UPPER RESPIRATORY
TRACT. ALUMINA IS A LOW HEALTH RISK BY INHALATION. ALUMINA SHOULD
BE TREATED AS NUISANCE DUST, AS S PECIFIED BY THE ACGIH. ACCORDING
TO AIHA HYGIENIC GUIDE:TOXICITY BY INGESTION:NONE EXPECTED. EYE &
SKIN:NOT AN IRRITANT.
Explanation of Carcinogenicity:MFR LISTED NO INFORMATION ABOUT THE
CARCINOGENICITY OF THIS MATERIAL. HMIS DOES NOT EXPECT IT TO BE
CARCINOGENIC.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:MFR GAVE NO INFORMATION ON MSDS.
======================= First Aid Measures =======================
First Aid:MFR GAVE NO INFORMATION ON MSDS.
===================== Fire Fighting Measures =====================
Extinguishing Media:PRODUCT IS NON-FLAMMABLE.
Fire Fighting Procedures:PRODUCT IS NON-FLAMMABLE
Unusual Fire/Explosion Hazard:NOT AN EXPLOSION HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP USING DRY PROCEDURES; AVOID DUSTING.
Neutralizing Agent:MFR GAVE NO INFORMATION ON MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:MFR GAVE NO INFORMATION ON MSDS.
Other Precautions:MFR GAVE NO INFORMATION ON MSDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE THE EXPOSURE LIMIT IS OR MAY BE EXCEEDED,
USE NIOSH/MSHA APPROVED RESPIRATORY PROTECTION. SELECT THE
APPROPRIATE RESPIRATOR (DUST RESPIRATOR) BASED ON THE ACTUAL OR
POTENTIAL AIRBORNE CONTAMINAN TS & THEIR CONCENTRATIONS PRESENT.
Ventilation:USE W/ADEQUATE VENTILATION TO MEET EXPOSURE LIMITS AS
LISTED IN INGREDIENT SECTION.
Other Protective Equipment:MFR GAVE NO INFORMATION ON MSDS.
Work Hygienic Practices:MFR: ?HMIS:USE GOOD INDUSTRIAL HYGIENE
PRACTICE. AVOID UNNECESSARY EXPOSURE. WASH THOROUGHLY BEFORE EATING
OR DRINKING
Supplemental Safety and Health
PH:10 (20% SLURRY SOLUTION).
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NONE
Melt/Freeze Pt:M.P/F.P Text:3700F,2038C
Spec Gravity:3.2
Solubility in Water:INSOLUBLE
Appearance and Odor:OFF-WHITE CRYSTALLINE OR GELATINOUS GRANULES,
PELLETS OR POWDER; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
GENERATES HEAT W/WATER.
Stability Condition to Avoid:MFR GAVE NO INFORMATION ON MSDS.
Hazardous Decomposition Products:MFR GAVE NO INFORMATION ON MSDS.
Conditions to Avoid Polymerization:MFR GAVE NO INFORMATION ON MSDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:MFR:WASTE MAY BE CONSIDERED AS INERT MATERIAL;
SUITABLE FOR LANDFILL. HMIS:DISPOSE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:C 111
Preparer's Name:D. MARTINSON
CAGE:25670
Contract Num:SP0920-98-M-3890
CAGE:30842
CAGE:25670
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ETHYL KETONE
CAS:78-93-3
RTECS #:EL6475000
= Wt:67.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:590 MG/M3;200 PPM
ACGIH TLV:590 MG/M3;200 PPM
ACGIH STEL:885 MG/M3;300 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV 200 PPM
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: EYE, SKIN, CENTAL
NERVOUS SYSTEM, RESPIRATORY AND GASTROINTESTINAL TRACTS. ACUTE AND
CHRONIC - EYE CONTACT MAY CAUSE IRRITATION AND BURNING SENSATION.
LIQUID CONTACT WILL DRY THE SKIN. PROLONGED OR REPEATED SKIN
CONTACT WITH LIQUID CAN RESULT IN DEFATTING AND DRYING OF THE SKIN
WHICH MAY RESULT IN SKIN IRRITATION AND DERMATITIS. INHALATION OF
VAPORS MAY CAUSE IRRITATION TO THE NOSE, THROAT AND RESPIRATORY
TRACT. HIGH VAPOR CONCENTRATIONS MAY CAUSE CENTRAL NERVOUS SYSTEM
(CNS) DEPRESSION. MAY BE HARMFUL IF SWALLOWED. MAY PRODUCE CNS
DEPRESSION. ASPIRATION HAZARD.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, NAUSEA,
VOMITING, DROWSINESS, COMA, EYE REDNESS, TEARNING, BLURRED VISION,
SKIN CRACKING, DEFATTING, DRYING, DERMATITIS, UNCONSCIOUSNESS,
GENERAL WEAKNESS, PULMONARY E DEMA, EXCITMENT, FATIGUE, DIARRHEA
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS OR IMPAIRED CENTRAL NERVOUS SYSTEM, OR
RESPIRATORY FUNCTION MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THIS
PRODUCT.
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALATION: REMOVE TO
FRESH AIR. GIVE ARTIFICAL RESPIRATION IF NOT BREATHING. IF
BREATHING IS DIFFICULT, OXYGEN MAY BE GIVEN BY QUALIFIED PERSONNEL.
EYE CONTACT: IMMEDIATELY FLUSH WITH WATER FOR AT LEAST 15 MINUTES.
HOLD EYELIDS OPEN. SKIN: WASH WITH SOAP AND PLENTY OF WATER FOR AT
LEAST 15 MINUTES. INGESTION: DO NOT INDUCE VOMITING. SEEK IMMEDIATE
MEDICAL ATT ENTION. IF VOMITING OCCURS, KEEP HEAD BELOW HIPS. DO
NOT GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:=-5.C, 23.F
Lower Limits:2.0%
Upper Limits:11.4%
Extinguishing Media:FOAM, ALCOHOL, C02, DRY CHEMICAL
Fire Fighting Procedures:NIOSH-APPROVED SELF CONTAINED BREATHING
APPARATUS IS REQUIRED FOR FIRES IN ENCLOSED AREAS.
Unusual Fire/Explosion Hazard:VOLATILE SOLVENT CONSTITUENT CAN READILY
FORM EXPLOSIVE OR FLAMMABLE MIXTURES IN AIR. VAPORS CAN FLOW ALONG
SURFACES TO DISTANT FOURCES AND FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. DO NOT WALK THROUGH SPILL; STOP SPILL
IF POSSIBLE. USE A VAPOR SUPPRESSING FOAM TO REDUCE VAPORS. CONTAIN
AND PICK UP WITH NON -FLAMMABLE ABSORBENT SUCH AS SAND,
VERMICULITE. GROUND ALL HANDLING EQUIPMENTS. PREVENT LIQUID FROM
ENTERING SEWERS, WATERWAYS, CONFINED SPACES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN WELL VENTILATED AREA. STORE
IN COOL PLACE. KEEP CONTAINER TIGHTLY CLOSED. STORE IN ACCORDANCE
WITH NATIONAL FIRE PROTECTION ASSOCIATION REGULATIONS. KEEP AWAY
FROM DIRECT SUNLIGHT, IGNITION S OURCES, AND INCOMPATIBLE
MATERIALS. USE ONLY NON-SPARKING TOOLS
Other Precautions:FLAMMABLE. EMPTY CONTAINERS RETAIN PRODUCT RESIDUES
(VAPORS, LIQUID, AND/OR SOLID) AND CAN BE DANGEROUS. DO NOT
PRESSURIZE, CUT, WELD, BRAZE, SOLDER OR DRILL. KEEP OUT OF REACH OF
CHILDREN. AVOID BREA THING VAPORS. DO NOT GET IN EYE, ON SKIN OR ON
CLOTHING. VAPOR CAN COLLECT IN FLOOR, DRAINS OR LOW A REAS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN RESTRICTED OR NON-VENTILATED AREAS WHERE
VAPOR EXPOSURE MAY BE ENCOUNTERED, USE RESPIRATOR WITH ORGANIC
SOLVENT VAPOR ADSORBING FILTER OR INDEPENTEND AIR SUPPLY.
Ventilation:MECHANICAL VENTILATION AND/OR LOCAL EXHAUST, SUFFICIENT IN
PATTERN AND VOLUME, TO MEET TLV REQUIREMENTS AND PREVENT EXPLOSIVE
CONCENTRATON OF SOLVENT VAPORS.
SKIN CONTACT IS LIKELY
RECOMMENDED.
Other Protective Equipment:EYE WASH FOUNTAIN OR BOTTLES. SOLVENT
INSOLUBLE BARRIER HAND CREAM.
Work Hygienic Practices:DO NOT USE CONTACT LENSES. WASH CONTAIMINATED
CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NONE LISTED.
================== Physical/Chemical Properties ==================
Boiling Pt:=79.4C, 175.F
Vapor Density:> AIR
Spec Gravity:0.9(H20=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NIL
Appearance and Odor:MEDIUM VISCOSITY BROWN LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT, POOR VENTILATION, SPARKS,
OPEN FLAMES, HOT SURFACES, STATIC ELECTRICITY AND OTHER SOURCES OF
IGNITION
Hazardous Decomposition Products:MAY FORM CARBON MONOXIDE, CARBON
DIOXIDE, NITROGEN OXIDES, PHENOLS,AND HYDROGEN CYANIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL,
STATE, AND FEDERAL LAWS AND REGULATIONS. SOLID INGREDIENTS ARE NOT
CONSIDERED HAZARDOUS.
===================== Regulatory Information =====================
SARA Title III Information:MEK IS SUBJECT TO REPORTING REQUIREMENTS OF
SECTION 313 OF SARA TITLE III AND OF 40 CFR PART 372.
State Regulatory Information:THIS PRODUCT MAY CONTAIN CHEMICALS KNOWN
TO THE STATE OF CALIFORNIA TO CAUSE CANCER AND/OR BIRTH DEFECTS OR
OTHER REPRODUCTIVE HARM.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CYCLOHEXANE, 9258
CAGE:DO811
CAGE:DO811
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:CYCLOHEXANE
CAS:110-82-7
RTECS #:GU6300000
Fraction by Wt: 98-100%
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT)29.8 G/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: HEADACHE, NAUSEA,
VOMITING, DIZZINESS, NARCOSIS, RESP FAILURE, LOW BLOOD PRESSURE,
CENTRAL NERVOUS SYSTEM DEPRESSION, SEVERE IRRITATION OF RESPIRATORY
SYSTEM. SKIN: IRRITATION, PROLONGED CONTACT MAY CAUSE DERMATITIS.
EYE: IRRITATION. SKIN ABSORP: NONE IDENTIFIED. INGEST: HDCH, NAUS,
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: VOMITING, DIZZINESS, GI IRRITATION,
CENTRAL NERVOUS SYSTEM DEPRESSION, HEARING LOSS, AND MAY BE FATAL.
CHRONIC: NONE IDENTIFIED. TARGET ORGANS: EYES, RESPIRATORY SYSTEM,
SKIN, CENTRAL NERVOU S SYSTEM.
Medical Cond Aggravated by Exposure:NONE IDENTIFIED.
======================= First Aid Measures =======================
First Aid:INGEST: CALL A PHYS. IF SWALLOWED, DO NOT INDUCE VOMITING.
INHAL: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTF RESP. IF
BREATHING IS DFCLT, GIVE OXYGEN. SKIN: FLUSH W/WATER. EYE: IMMED
FLUSH WITHPLENTY OF WATER FOR AT LEAST 15 MINUTES.
===================== Fire Fighting Measures =====================
Flash Point:-2F,-19C
Lower Limits:1.3%
Upper Limits:8.4%
Extinguishing Media:USE ALCOHOL FOAM, DRY CHEMICAL OR CARBON DIOXIDE.
(WATER MAY BE INEFFECTIVE).
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP. MOVE
CONTRS FROM FIRE AREA IF IT CAN BE DONE W/OUT RISK. USE WATER TO
KEEP FIRE-EXPOSED CONTRS COOL.
Unusual Fire/Explosion Hazard:VAPS MAY FLOW ALONG SURF TO DISTANT IGNIT
SOURCES & FLASH BACK. CLSD CONTRS EXPOSED TO EXTREME HEAT MAY
EXPLODE. CONT W/STRONG OXIDIZERS MAY CAUSE FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT CLTHG.
SHUT OFF IGNIT SOURCES; NO FLARES, SMOKING/FLAMES IN AREA. STOP
LEAK IF YOU CAN DO SO W/OUT RISK. USE WATER SPRAY TO REDUCE VAPS.
TAKE UP W/SAND/OTHER NO N-COMBUST ABSORB MATL & PLACE INTO CONTR
(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN A COOL, DRY, WELL-VENTILATED, FLAMMABLE LIQUID STORAGE AREA.
KEEP AWAY FROM HEAT, SPARKS, FLAME.
Other Precautions:AVOID CONTACT WITH EYES, SKIN, CLOTHING. AVOID
BREATHING VAPOR. BOND AND GROUND CONTAINERS WHEN TRANSFERRING
LIQUID.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATORY PROTECTION REQUIRED IF AIRBORNE
CONCENTRATION EXCEEDS TLV. @ CONC UP TO 1000 PPM, A NIOSH/MSH
APPROVED CHEM CARTRIDGE RESP W/ORGANIC VAPOR CARTRIDGE IS
RECOMMENDED. ABOVE THIS LEVEL, A NIO SH/MSHA APPROVED SCBA IS
RECOMMENDED.
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO MEET TLV
REQUIREMENTS.
Other Protective Equipment:UNIFORM, APRON.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
SPILL PROC: FOR LATER DISPOSAL. FLUSH AREA W/WATER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:178F,81C
Melt/Freeze Pt:M.P/F.P Text:44.6F,7.0C
Vapor Pres:95@20C
Vapor Density:2.9
Spec Gravity:0.78(H*2O=1)
Evaporation Rate & Reference:>1(BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE(<0.1%)
Appearance and Odor:CLEAR, COLORLESS LIQUID, FAINT ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, FLAME, OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W ALL APPLICABLE FEDERAL, STATE, AND
LOCAL ENVIRONMENTAL REGULATIONS. EPA HAZARDOUS WASTE NUMBER
U056(TOXIC WASTE).
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PHOSGENE IMINIUM CHLORIDE, TECH, 162876
CAGE:21076
CAGE:21076
============= Composition/Information on Ingredients =============
Ingred Name:CHLORIDES; (PHOSGENE IMINUM CHLORIDE, TECH)
CAS:33842-02-3
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: HARMFUL IF INHALED OR
SWALLOWED. CAUSES SEVERE IRRITATION. HIGH CONCENTRATIONS ARE
EXTREMELY DESTRUCTIVE TO TISSUES OF THE MUCOUS MEMBRANES AND UPPER
RESPIRATORY TRACT, EYES AND SKIN. SYMPTOMSOF EXPOSURE MAY INCLUDE
BURNING SENSATION, COUGHING, WHEEZING, LARYNGITIS, SHORTNESS OF
BREATH, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: HEADACHE, NAUSEA AND VOMITING. TO THE
BEST OF MANUFACTURER'S KNOWLEDGE, THE CHEMICAL, PHYSICAL AND
TOXICOLOGICAL PROPERTIES HAVE NOT BEEN THOROUGHLY INVESTIGATED.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH EYES W/COPIOUS AMOUNTS OF WATER FOR AT LEAST 15
MIN. SKIN: FLUSH SKIN W/COPIOUS AMOUNTS OF WATER FOR AT LEAST 15
MIN WHILE REMOVING CONTAMINATED CLOTHING & SHOES. INHAL: REMOVE TO
FRESH AI R. IF NOT BREATHING GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. INGEST: WASH OUT MOUTH W/WATER
PROVIDED PERSON IS CONSCIOUS. CALL MD. WASH CONTAMINATED CLOTHING
BEFORE REUSE.
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER, WATER SPRAY.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR NIOSH APPROVED
SELF-CONTAINED BREATHING APPARATUS, RUBBER BOOTS & HEAVY RUBBER
RAISING DUST. VENTILATE AREA & WASH SPILL SITE AFTER MATERIAL
PICKUP IS COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:HARMFUL SOLID. KEEP TIGHTLY CLOSED.
READILY HYDROLYZED. REFRIGERATE.
Other Precautions:DO NOT BREATHE DUST. DO NOT GET IN EYES, ON SKIN, ON
CLOTHING. AVOID PROLONGED OR REPEATED EXPOSURE. WASH THOROUGHLY
AFTER HANDLING. SEVERE IRRITANT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
WEAR PROTECTIVE CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
EYE PROT: & FULL LENGTH FACESHIELD.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:>361F,>183C
Appearance and Odor:WHITE TO PALE-YELLOW POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:MOISTURE.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
NITROGEN OXIDES, HYDROGEN CHLORIDE GAS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE OR MIX THE MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. OBSERVE ALL FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:VARGLAS SILICONE RUBBER SLEEVING
CAGE:79074
CAGE:79074
============= Composition/Information on Ingredients =============
Ingred Name:FIBERGLASS-SIO*2, NA*2CO*3, CAO
Fraction by Wt: N.A.
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3(TOTAL DUST)
ACGIH TLV:10 MG/M3 (DUST)
Ingred Name:SILICONE RUBBER-VINYL, METHYL & PHENYL
Fraction by Wt: N.A.
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:YES
Health Hazards Acute and Chronic:ACUTE: SKIN-TRANSIENT MECHANICAL
IRRITATION. EYE-DIRECT CONTACT WILL CAUSE MECHANICAL IRRITATION.
INGEST-UNLIKELY TO OCCUR. CHRONIC: SKIN-NONE. EYE-NONE.
INGEST-NONE.
Explanation of Carcinogenicity:NO EXPLANATORY NOTE OR ADDITIONAL
INFORMATION SUPPLIED BY MANUFACTURER ON CARCINOGENITY.
Effects of Overexposure:OBSERVE INDIVIDUAL. IF SYMPTOMS DEVELOP,
CONSULT PHYSICIAN.
Medical Cond Aggravated by Exposure:SKIN PROBLEMS.
======================= First Aid Measures =======================
First Aid:WASH EXPOSED AREAS WITH SOAP AND WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:STANDARD FIRE EXTINGUISHER.
Fire Fighting Procedures:WEAR FACE MASK AND SCBA APPROVED BY U.S.
BUREAU OF MINES.
Unusual Fire/Explosion Hazard:NO EXPLOSIVE HAZARD.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A FACE MASK.
Ventilation:USE LOCAL EXHAUST OR MECHANICAL (GENERAL) VENTILATION.
Other Protective Equipment:NONE
Work Hygienic Practices:WASH EXPOSED AREAS WITH SOAP AND WATER.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NONE
Spec Gravity:2.25
Solubility in Water:INSOLUBLE
Appearance and Odor:CONTINUOUS FILM OF SILICONE RUBBER ON "FIBERGLAS"
BRAID. NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:CONDITIONS ABOVE 250C WITHOUT ADEQUATE
VENTILATION.
Hazardous Decomposition Products:METHYL & PHENYL BY PRODUCTS.
Conditions to Avoid Polymerization:TEMPERATURES IN EXCESS OF 240C.
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL IS PREFERRED, BUT DISPOSAL METHOD MUST
CONFORM TO FEDERAL, STATE AND LOCAL REGULATIONS. BURNING NOT
RECOMMENDED.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:TURCO DY-CHEK PENETRANT
CAGE:D9808
CAGE:61102
CAGE:D9808
============= Composition/Information on Ingredients =============
Ingred Name:ALIPHATI PETROLEUM SOLVENT (CAS #8002-05-9)
Fraction by Wt: 55.0%
ACGIH TLV:350 PPM
Ingred Name:DIBUTYL PHTHALATE (SARA III)
CAS:84-74-2
RTECS #:TI0875000
Fraction by Wt: 40.0%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3; 9192
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
Effects of Overexposure:EYES:MOD IRRIT,REDNESS/TEAR;SKIN:MOD
IRRIT,DRY;INH:MOD IRRIT IF MIST INHALED;*SEE OTHER PRECAUTIONS.
======================= First Aid Measures =======================
First Aid:SKIN/EYES:FLUSH W/WATER.IFIRRITATION PERSISTS,CALL A
DR.ING:DO NOT INDUCE VOMITING.GET MED ATTN IMMED;INH:REMOVE TO
FRESH AIR.IF BREATHING IS DIFFICULT,GIVE OXYGEN & GET MED HELP AT
ONCE.
===================== Fire Fighting Measures =====================
Flash Point:140F TCC
Lower Limits:UNK
Upper Limits:UNK
Extinguishing Media:CARBON DIOXIDE
Fire Fighting Procedures:NONE KNOWN
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA.ELIMINATE SOURCE OF IGN.WEAR
PROTECTIVE EQUIP.DAM UP W/SANDBAGS OR SOAK UP ON ABSORBENT
MATERIALS.PUMP LIQ &/OR SWEEP ABSORBED LIQ INTO SELABLE CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS AT A
TEMPERATURE BETWEEN 30 & 120F.
Other Precautions:*EFFECTS OVEREXPOSURE;INGESTION:DAMAGE TO THROAT
ESOPHOGAS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR W/MECHANICAL FILTER FOR MIST
CONDITIONS.
Ventilation:LOCAL./MECHANICAL (GEN)
Supplemental Safety and Health
CAS #8002-05-9 LISTED FOR PETROLEUM DISTILLATE.
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:370F
Vapor Pres:UNK
Vapor Density:>1.0
Spec Gravity:0.89
Evaporation Rate & Reference:<1.0(BU ACETATE)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DEEP RED LIQ;DI-BUTYL PHTHALATE ODOR
Percent Volatiles by Volume:55.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS & CORROSIVES
Stability Condition to Avoid:SOURCE OF FLAME/IGN.
Hazardous Decomposition Products:CARBON DIOXIDE
Conditions to Avoid Polymerization:UNK
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE LIQ IN AN APPROVED INCINERATOR OR
DISPOSE OF IN THE APPROVED LANDFILL IAW APPLICABLE FEDERAL,STATE &
LOCAL REGULATIONS.(IF MIXED W/WATER SEPARATE OUT OIL FRACTION)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ACETONE
Preparer's Name:DGSC-SSH
CAGE:97984
CAGE:97984
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 100%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS > 6000 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HEALTH HAZARDS- ACUTE: MODERATE EYE
IRRITATION AND MODERATE CORNEAL INJURY. INHALATION MAY CAUSE
ANESTHETIC OR NARCOTIC EFFECTS. CHRONIC: EYES AND RESPIRATORY TRACT
IRRITATION.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYES: MODERATE IRRITATION, CORNEAL INJURY.
SKIN: IRRITATION, DRYING, FLAKING. INHALATION: UPPER RESPIRATORY
TRACT IRRITATION, HEADACHE, DIZZINESS, DROWSINESS. INGESTION: NO
HAZARD ANTICIPATED FROM ING ESTION INCIDENTAL TO INDUSTRIAL
EXPOSURE. IF INGESTED INTENTIONALLY, SEVERE HEARTBURN-LIKE
SYMPTOMS, AND NAUSEA.
Medical Cond Aggravated by Exposure:NONE NOTED.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES. SEE DOCTOR. SKIN: WASH OFF IN FLOWING WATER OR SHOWER.
INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
MOUTH-TO-MOUTH RESU SCITATION. IF BREATHING IS DIFFICULT, GIVE
OXYGEN. CALL A PHYSCIAN. INGESTION: INDUCE VOMITING IF LARGE
AMOUNTS ARE INGESTED. SEE DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:0F,-18C
Lower Limits:2
Upper Limits:13
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:HEAT OF FIRE MAY RUPTURE CONTAINERS.
COMBUSTION OR HEAT OF FIRE MAY PRODUCE HAZARDOUS DECOMPOSITION
PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:ALLOW TO EVAPORATE IF IT CAN BE DONE SAFELY.
OTHERWISE, SOAK UP IN ABSORBENT MATERIAL AND SCOOP UP INTO DRUMS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA, AWAY FROM HEAT, IGNITION SOURCES AND INCOMPATIBLE MATERIALS.
KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE MIST. AVOID
PROLONGED OR REPEATED BREATHING OF VAPOR. AVOID CONTACT WITH EYES.
USE WITH ADEQUATE VENTILATION. USE SPARK-RESISTANT TOOLS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED WITH ADEQUATE
VENTILATION. NIOSH/MSHA-APPROVED RESPIRATOR WITH ORGANICS CARTRIDGE
OR APPROVED POSITIVE-PRESSURE SELF-CONTAINED BREATHING APPARATUS AS
APPROPIATE FOR EXPOSURE OFCONCERN.
Ventilation:LOCAL EXHAUST VENTILATION. USE EXPLOSION-PROOF EQUIPMNENT.
USE ONLY WITH ADEQUATE VENTILATION.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
USE ONLY WITH ADEQUATE VENTILATION. LETHAL DOSES MAY EXIST IN AREAS
WITH POOR VENTILATION. MSDS PREPARED BY DGSC-SSH.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:133F,56C
Melt/Freeze Pt:M.P/F.P Text:-142F,-97C
Vapor Pres:184
Vapor Density:2
Spec Gravity:0.79
Evaporation Rate & Reference:14 (BUTYL ACETATE = 1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID, SWEET ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
INCOMPLETELY BURNED CARBON PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND
LOCAL REGULATIONS. MANUFACTURER RECOMMENDS INCINERATION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:POLAR CUT 405L
CAGE:16509
CAGE:16059
CAGE:16509
============= Composition/Information on Ingredients =============
Ingred Name:DIETHANOLAMINE (SARA III)
CAS:111-42-2
RTECS #:KL2975000
Fraction by Wt: 1-5%
OSHA PEL:3 PPM
ACGIH TLV:3 PPM; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ETHANOL, 2,2',2"-NITRILOTRI-; (TRIETHANOLAMINE).
LD50:(ORAL,RAT) 8000 MG/KG.
CAS:102-71-6
RTECS #:KL9275000
Fraction by Wt: 1-5%
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: MAY CAUSE MODERATE TO
SEVERE EYE IRRITATION. SKIN: MODERATE SKIN IRRITANT. INHAL: INHAL
OF MIST GENERATED DURING WORKING CONDITIONS MAY CAUSE IRRITATION.
INGEST: LOW ORAL TOXICITY FOR SMA LL AMOUNTS ASSOCIATED WITH
INDUSTRIAL HANDLING. CHRONIC: CHRONIC FEEDING STUDIES WITH CONC TEA
(SEE EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: AND DEA HAVE SHOWN LIVER, KIDNEY AND
CNS DAMAGE IN RATS AND GUINEA PIGS. SOME LIVER AND KIDNEY EFFECTS
HAVE BEEN SEEN IN ONE STUDY ON RATS SUBJECTED TO PROLONGED, DERMAL
DOSING.
Medical Cond Aggravated by Exposure:NONE REPORTED.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. CONSULT A
PHYSICIAN. SKIN: WASH AFFECTED AREA WITH SOAP AND WATER. REMOVE
CONTAMINATED CLOTHING. INHAL: REMOVE PATIENT TO FRESH AIR. INGEST:
INDUCE VOMI TING IF LARGE AMOUNTS ARE INGESTED. GIVE 2 GLASSES OF
WATER TO DILUTE.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:325F,163C
Extinguishing Media:WATER, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . USE OF CHLORINATED SOLVENT FIRE
EXTINGUISHERS SHOULD BE AVOIDED.
Unusual Fire/Explosion Hazard:NO*X MAY BE GENERATED IN A RAGING FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:MOP UP OR USE DRY ABSORBENTS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED FOR NORMAL USE. IF WORKING
CONDITIONS GENERATE MISTS IN A CONFINED AREA, A NIOSH/MSHA APPROVED
ORGANIC VAPOR RESPIRATOR SHOULD BE WORN.
Ventilation:MATL DOES NOT GIVE OFF HAZ VAPORS. IF WORK CONDITIONS
GENERATE MIST, VENTILATION (100 LINEAR FEET/MINUTE) IS REC.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PH: 8.5-9.0.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:30.0F,-1.1C
Vapor Pres:22 @ 68F
Vapor Density:0.63
Spec Gravity:1.0
pH:SUPDAT
Evaporation Rate & Reference:<1 (BUTYL ACETATE = 1)
Solubility in Water:100%
Appearance and Odor:AMBER LIQUID WITH MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SUBSTANCES THAT REACT WITH WATER.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:IN A RAGING FIRE, NO*X MAY BE EVOLVED.
==================== Disposal Considerations ====================
Waste Disposal Methods:MAY BE DISPOSED OF ACCORDING TO FEDERAL, STATE
AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SUPER LUBE AEROSOL CAN
CAGE:4Y181
CAGE:4Y181
============= Composition/Information on Ingredients =============
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROETHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 69%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:350 PPM
ACGIH TLV:350 PPM/450STEL;9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED OR REPEATED SKIN CONTACT MAY
CAUSE DERMATITIS. CAN CAUSE HEADACHE, MENTAL CONFUSION, DEPRESSION,
FATIGUE, LOSS OF APPETITE, COUGHING, VOMITING, LOSS OF SENSE OF
BALANCE, AND VISUAL DISTURBAN CES. MODERATE IRRITANT TO RESPIRATORY
TRACT.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:CHLOROCARBON/CHLOROFLUOROCARBON (CFC) MATERIALS
HAVE PRODUCED SENSIT OF MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS &
COULD HAVE A SIMILAR EFFECT IN HUMANS. ADRENOMIMETICS (E.G.,
EPINEPHRINE) MAY BE CONT RAINDICATED EXCEPT FOR LIFESUSTAINING USES
IN HUMANS ACUTELY OR CHRONICALLY EXPOSED TO CHLOROCARBONS OR CFC'S
.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MINUTES. SKIN: WASH AREA
W/SOAP & WATER. INHAL: GET PERSON TO FRESH AIR. SEEK IMMEDIATE
MEDICAL ATTENTION. INGEST: DO NOT INDUCE VOMITING. SEEK IMMEDIATE
MEDICAL AT TENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:8.0%
Upper Limits:10.5%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
& FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CONTENTS UNDER PRESSURE; EXPOSURE TO
TEMPS IN EXCESS OF 130F MAY CAUSE BURSTING. THERMAL DECOMP PRODUCTS
MAY INCLUDE HCL & PHOSGENE .
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT PUNCTURE, INCINERATE, OR STORE
WHERE TEMPS EXCEED 130F.
Other Precautions:KEEP OUT OF THE REACH OF CHILDREN. NO SMOKING IN AREA
OF USE. DO NOT USE IN GENERAL VICINITY OF ARC WELDING, OPEN FLAMES
OR HOT SURFACES. HEAT &/OR UV RADIATION MAY CAUSE FORMATION OF HCL
&/OR PHOSGEN E .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN ABSENCE OF ADEQUATE VENTILATION, USE
NIOSH/MSHA APPROVED VAPOR RESPIRATOR.
Ventilation:USE LOCAL EXHAUST WITH ADEQUATE VENTILATION.
Other Protective Equipment:TRAIN EMPLOYEES IN PROPER USE; FOLLOW LABEL
DIRECTIONS!
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:165.4
Melt/Freeze Pt:M.P/F.P Text:34.4F,1.3C
Vapor Pres:125
Vapor Density:4.55
Spec Gravity:1.32
Evaporation Rate & Reference:0.35 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE GREASE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:DO NOT STORE WHERE TEMPS EXCEED 130F.
Hazardous Decomposition Products:HCL, PHOSGENE .
==================== Disposal Considerations ====================
Waste Disposal Methods:REPLACE CAN & DISCARD CONTAINER IN TRASH. DO NOT
INCINERATE OR PUNCTURE. DISPOSE OF ALL WASTE IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FORMULA 300, 1113
CAGE:0990Y
CAGE:27674
CAGE:0990Y
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC
CAS:64742-88-7
Fraction by Wt: 40-50%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:METHANE, DICHLORO-; (METHYLENE CHLORIDE) (SARA 313)
(CERCLA)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 10-20%
OSHA PEL:500 PPM; Z-2
ACGIH TLV:50 PPM, A2
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYLENE, TETRACHLORO-; (PERCHLOROETHYLENE)
(TETRACHLOROETHYLENE) (SARA 313) (CERCLA)
CAS:127-18-4
RTECS #:KX3850000
Fraction by Wt: 30-40%
OSHA PEL:100 PPM, Z-2
ACGIH TLV:25 PPM/100 STEL, A3
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:SUPDAT:MAY CAUSE CHEM PNEUM. CHRONIC:PRTD/PRLNGD CONT BY
INHAL/SKIN ABSORP MAY PRDCE LIVER/KIDNEY DMG/DMG TO (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:CNS, CHARACT BY TINGLING/NUMBNESS IN EXTREMITIES,
BLURRED VISION/CONFSN. SKIN, WHICH IS DEFAT BY RPTD (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:EXPOS TO SOLV, IS MORE SUSCEPTIBLE TO IRRIT,
INFECTION, & DERM.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:GET MEDICAL ATTENTION AT ONCE.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH:LANDFILL, CONSULT LOC, ST, & FED AGENCIES
FOR PROPER DISP METH IN YOUR AREA.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:CHLOROCARBON MATLS HAVE PRDCED SENSIT
OF MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS & COULD HAVE A SIMILAR
EFT IN HUMANS. ADRENOMIMETICS (E.G. EPINEPHRINE) MAY BE
CONTRAINDICATED EXCEPT FOR LIFE-SUSTAIN ING USES IN HUMANS
ACUTELY/CHRONICALLY EXPOS TO CHLOROCARB . ACUTE:INHALATION OF VAPOR
CAN PRDCE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:METHYLENE CHLORIDE:IARC MONO SUPP, VOL
7, PG 194, 1987:GROUP 2B. NTP 7TH ANNUAL RPT ON CARCIN, 1994:ANTIC
TO BE (SUPDAT)
Effects of Overexposure:HLTH HAZ:CNS DEPRESS, CHARACTERIZED BY DIZZ,
HDCH, NAUS, CARDIAC AND/OR RESP DEPRESS, STUPOR, UNCON & DEATH, IN
EXTREME CASES. EXPOS TO HIGH CONC OF VAP BY DIRECT CONT/INHAL CAN
BE IRRITATING TO MUC M EMB, SUCH AS EYES & UPPER RESP TRACT. SEV
EYE EXPOS TO LIQ CAN CAUSE REVERSIBLE EYE DMG. SKIN CONT MAY CAUSE
(SUPDAT)
Medical Cond Aggravated by Exposure:EXPOSURE TO THIS PRODUCT MAY
AGGRAVATE EXISTING RESPIRATORY AND CARDIAC CONDITIONS.
======================= First Aid Measures =======================
First Aid:SKIN:IMMED FLUSH CONTAMD SKIN W/PLENTY OF WATER FOR @ LEAST
15 MINS. GET MED ATTN IMMED. EYES:IMMED FLUSH W/PLENTY OF WATER FOR
@ LEAST 15 MINS, OCCASNLY LIFTING UPPER & LOWER LIDS. GET MED ATTN
@ ONC E. INHAL:MOVE EXPOS PERSON TO FRESH AIR@ ONCE. IF BRTHG HAS
STOPPED, PERFORM ARTF RESP. GET MED ATTN IMMED. INGEST:DO NOT
INDUCE VOMIT. IF VICTIM IS CONSCIOUS GIVE PLENTY OF WATER TO DRINK.
(ING 7)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:170F,77C
Lower Limits:1.0%
Upper Limits:15%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL AND FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
& FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE HCL & PHOSGENE . CONCENTRATED VAPOR MAY IGNITE IF EXPOSED
TO SPARK.
================== Accidental Release Measures ==================
Spill Release Procedures:IMMED ELIM ALL FLAME, IGNIT & HIGH-HEAT
SOURCES. ABSORB SPILL ON INERT ABSORB MATL (EG ZEP-O-ZORB). PICK UP
& PLACE RESIDUE IN CLEAN, D.O.T. SPECIFICATION CNTNR FOR DISP. WASH
AREA THORO W/DETERGENT S OLN & RINSE WELL WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE TIGHTLY CLSD CNTNR IN DRY AREA @
TEMPS BETWEEN 40-120F. KEEP PROD AWAY FROM SKIN & EYES. DO NOT
BREATH SPRAY MISTS/VAP. DO NOT WEAR CONT LENSES.
Other Precautions:KEEP AWAY FROM FOOD & FODD PROD. KEEP OUT OF REACH OF
CHILDREN. NO SMOKING IN AREA OF USE. DO NOT USE IN GEN VICINITY OF
ARC WELDING, OPEN FLAMES/HOT SURF. HEAT &/OR UV RADIA MAY CAUSE
FORMATION OF HC L &/OR PHOSGENE .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENT IS INADEQ, WEAR NIOSH/MSHA APPRVD
PROPERLY FITTED RESPIRATOR.
Ventilation:EQUIVALENT TO OUTDOORS. USE EXHAUST FANS AND OPEN WINDOWS
IN ENCLOSED SPACES.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLAN OF CARCIN:CARCIN. ANIMAL:LUNG,LIV,SALIVARY, MAMMARY GLAND
(TUMORS). TETRACHLOROETHYLENE:IARC MONO, SUPP. VOL 7, PG 355,
1987:GROUP 2B. NTP 7TH ANNUAL RPT ON CARCIN; ANTIC TO BE CARCIN.
EFTS OF OVEREXP:BURNING SENSATION & REDDENING OF SKIN.
INTRODUCTION OF SOLV TO LUNGS, AS IN ASPIR OF VOMITUS FLUIDS, (ING
4)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:102F,39C
Vapor Pres:90
Vapor Density:4.89
Spec Gravity:1.05
Evaporation Rate & Reference:2.5 (CCL*4 =1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:THIN, CLEAR LIQUID WITH STRONG, SWEET SOLVENT ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CERTAIN PLASTICS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:HCL & PHOSGENE . MAY DECOMPOSE TO FORM
TOXIC OR CORROSIVE GASES IF EXPOSED TO HIGH HEAT.
==================== Disposal Considerations ====================
Waste Disposal Methods:LIQ CANNOT BE SENT TO LANDFILLS UNLESS
SOLIDFIED. UNUSABLE PROD & COLLECTED, SPENT MATL MAY REQ DISP AS
HAZ WASTE @ PERMITTED TREATMENT/STOR/DISP FACILITY. SOLV WASTES MAY
REQ TREATMENT TO MEET APPROP STDS BEFORE DISP IN CHEM/INDUST WASTE
(ING 8)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:C-70 SPACKLING & GLAZING COMPOUND, CAULKS, (SUPDAT)
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA, LIGHT. VP: 12.0
CAS:64742-89-8
Fraction by Wt: 5%
OSHA PEL:300 PPM (MFR)
ACGIH TLV:300 PPM (MFR)
Ingred Name:SOLVENT NAPHTHA, PETROLEUM MEDIUM ALIPH. VP: 2.0
CAS:64742-88-7
Fraction by Wt: 6%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (QUARTZ)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 56%
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST;9495
Ingred Name:SUPDAT: DRIED FILM, WEAR A DUST/MIST RESPIRATOR APPROVED BY
NIOSH FOR PROT AGAINST NON-VOLATILE MATERIALS IN SECTION 2.
RTECS #:9999999ZZ
Ingred Name:EXPLAN OF CARCINOGEN: TO BE CARCINOGEN. (HUMAN: LUNG).
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRITATION OF EYES, SKIN AND
RESPIRATORY SYSTEM. IN A CONFINED AREA VAPORS IN HIGH CONCENTRATION
MAY CAUSE HEADACHE, NAUSEA OR DIZZINESS. SIGNS AND SYMPTOMS OF
OVEREXPOSURE: REDNESS AND ITCHING OR BURNING SENSATION MAY
INDICATE EYE OR EXCESSIVE SKIN EXPOSURE. CHRONIC: LONG TERM
EXPOSURE TO (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE QUARTZ: IARC
MONOGRAPHS, VOL 68, 1997: GRP 1. NTP 7TH ANNUAL RPT ON CARCIN,
1994: ANTIC (ING 5)
Effects of Overexposure:HLTH HAZ: HIGH LEVELS OF SILICA DUST, WHICH CAN
OCCUR ONLY WHERE SANDING OR ABRADING THE DRY FILM, MAY CAUSE LUNG
DAMAGE (SILICOSIS) AND POSSIBLY CANCER. PROLONGED OVEREXPOSURE TO
MINERAL SPIRITS OR V M & P NAPHTHA MAY CAUSE ADVERSE EFFECTS TO
THE LIVER AND URINARY SYSTEMS.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM AND
QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP AND WATER.
REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE RE-USE. EYES: FLUSH
EYES W ITH LARGE AMOUNTS OF WATER FOR AT LEAST15 MINUTES. GET
MEDICAL ATTENTION. INGEST: SEEK MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F,>93C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER SPRAY MAY BE INEFT. IF H*2O IS USED, FOG NOZZLES ARE PREF.
H*2O MAY BE USED TO COOL CLSD CNTNRS (SUPDAT)
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO THE
BUILD-UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AND REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
TRANSFER ONLY TO APPROVED CONTAINERS WITH COMPLETE AND APPROPRIATE
LABELING. DO NOT TAKE INTERNALLY.
Other Precautions:KEEP OUT OF THE REACH OF CHILDREN. CA PROPOSITION 65:
WARNING: THESE PRODUCTS, EXCEPT FOR C-99, CONTAIN A CHEMICAL(S)
KNOWN TO THE STATE OF CA TO CAUSE CANCER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERS EXPOS CANNOT BE CONTROLLED BELOW APPLIC
LIMS BY VENT, WEAR A PROPERLY FITTED ORG VAP/PARTICULATE RESP
APPRVD BY NIOSH FOR PROT AGAINST MATLS IN SECTION 2. WHEN
SANDING/ABRADING DRIED FILM, WEA R A DUST/MIST RESP APPRVD (SUPDAT)
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPTABLE IF THE EXPOS TO MATLS
IN SECTION 2 IS MAINTAINED BELOW APPLIC EXPOS LIMS. (SUPDAT)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
MFR'S TRADE NAME/PART #:SPACKLING COMPOUNDS, FILLER & SEALANTS. FIRE
FIGHT PROC: TO PVNT PRESS BUILD-UP & POSS AUTOIGNITION/EXPLOSION
WHEN EXPOSED TO EXTREME HEAT. VENT: REFER TO OSHA STDS 1910.94, 19
10.107, 1910.108. RESP PROT:BY NIOSH FOR PROT AGAINST MATLS IN
SECTION II. WHEN SANDING/ABRADING THE DRIED (ING 4)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Vapor Density:HVR/AIR
Spec Gravity:1.47
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:SPACKLING & GLAZING COMPOUND
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THESE PRODUCT IS NOT HAZARDOUS AS
DEFINED UNDER THE RCRA 40 CFR 261. DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE, AND LOCAL REGULATIONS REGARDING POLLUTION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:STRIPER PAINT STP 1-8
CAGE:OB6T7
CAGE:OB6T7
============= Composition/Information on Ingredients =============
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Other REC Limits:450 PPM STEL
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYLENE CHLORIDE(SARA III)
CAS:75-09-2
RTECS #:PA8050000
OSHA PEL:500 PPM/C,1000; Z2
ACGIH TLV:50 PPM, A2; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Other REC Limits:450 PPM STEL
OSHA PEL:350 PPM/450 STEL
ACGIH TLV:350 PPM/450STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:LEAD CHROMATE, CR, CHROME GREEN, CHROME YELLOW (SUSPECTED
HUMAN CARCINOGEN BY ACGIH, IARC & NTP)
CAS:7758-97-6
RTECS #:GB2975000
OSHA PEL:0.5 MG/CUM PB
ACGIH TLV:0.05 MG/CUM CR (A2)
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
CAS:75-28-5
RTECS #:TZ4300000
Other REC Limits:1000 PPM
OSHA PEL:1800 MG/CUM
ACGIH TLV:1000 PPM
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9192
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: DIZZINESS, DROWSINESS,
THROAT IRRITATION, CARDIAC SENSITIZATION, VENTRICULAR ARRHYTHMIA,
UNCONSCIOUSNESS, & DEATH. SKIN: DEFATTING & DRYNESS. EYES:
IRRITATION. INGESTION: CHEMICAL PNEUMONI A.
Explanation of Carcinogenicity:DICHLOROMETHANE & LEAD CHROMATE ARE
SUSPECTED A2 CARCINOGENS.
Effects of Overexposure:INHALATION: DIZZINESS, DROWSINESS, THROAT
IRRITATION, CARDIAC SENSITIZATION, VENTRICULAR ARRHYTHMIA,
UNCONSCIOUSNESS, & DEATH. EYES: IRRITATION. SKIN: DEFATTING &
DRYNESS. INGESTION: CHEMICAL PNEUMONI A.
Medical Cond Aggravated by Exposure:ACUTE & CHRONIC LIVER/KIDNEY
DISEASE, CHRONIC LUNG DISEASE, ANEMIA, CORONARY DISEASE, & RHYTHM
DISORDERS OF THE HEART
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE ARTIFICIAL RESPIRATION
IF BREATHING HAS STOPPED. EYES: FLUSH W/PLENTY OF WATER. SKIN: WASH
W/SOAP & WATER & APPLY MEDICATED SKIN CREAM. INGESTION: DON'T
INDUCE VO MITING. OBTAIN MEDICAL ATTENTION IN ALLCASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, POWDER OR FOAM
Fire Fighting Procedures:USE HIGH SPRAY OF WATER TO KEEP AEROSOLS COOL.
WEAR SELF-CONTAINED POSITIVE PRESSURE BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:EXCESSIVE HEAT CAUSED BY FIRE WILL CAUSE
AEROSOLS TO BURST.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE & VENTILATE AREA. CONTAIN THE SPILL.
REMOVE LEAKING CONTAINER & TRANSFER PRODUCT TO ANOTHER VESSEL.
CLEAN UP BY MOPPING OR SOAK UP W/ABSORBENT MATERIAL. DON'T FLUSH TO
SEWER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AEROSOL <120F & >32F. STORE ALL
MATERIALS IN DRY, WELL-VENTILATED AREA. AVOID INHALATION OF VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED IF GOOD VENTILATION EXISTS. FOR
ENCLOSED AREA USE NIOSH APPROVED ORGANIC VAPOR CARTRIDGE.
Ventilation:MECHANICAL: RECOMMENDED IN ENCLOSED AREAS.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER USE. REMOVE/LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
EVAPORATION RATE (BU AC = 1): XYLENE= 0.88; DICHLOROMETHANE= 14.5;
1,1,1, TRICHLOROETHANE= 3.5.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:104F
Vapor Pres:355
Vapor Density:<1
Spec Gravity:1.27
Evaporation Rate & Reference:SEE SUPP
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID PAINTS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, OXIDIZERS, & REACTIVE METALS SUCH AS ALUMINUM &
MAGNESIUM
Stability Condition to Avoid:EXCESSIVE HEAT FROM FIRE, OPEN FLAME,
ELECTRIC ARCS, & OTHER HOT SURFACES
Hazardous Decomposition Products:HYDROGEN CHLORIDE & SMALL AMOUNTS OF
PHOSGENE
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE IN CLOSED CONTAINER. DISPOSE OF IN
ACCORDANCE W/LOCAL, STATE, & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RPC-044 2,3',4,4',6-PENTACHLOROBIPHENYL
CAGE:0MU35
CAGE:0MU35
============= Composition/Information on Ingredients =============
Ingred Name:2,3',4,4',6-PENTACHLOROBIPHENYL
CAS:56558-17-9
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TOXIC; IRRITANT. TOXIC MATERIAL
CAUSING OTHER TOXIC EFFECTS.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/COPIOUS AMOUNTS OF WATER. INHALATION:
REMOVE TO FRESH AIR. GIVE OXYGEN IF NECESSARY. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, DRY CHEMICAL POWDER/WATER SPRAY.
================== Accidental Release Measures ==================
Spill Release Procedures:LEAKING BOTTLE MAY BE PLACED IN A PLASTIC BAG
& NORMAL DISPOSAL PROCEDURES FOLLOWED. LIQUID SAMPLES MAY BE
ABSORBED ON VERMICULITE/SAND.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP TIGHTLEY CLOSED & STORE IN A
COOL/DRY PLACE.
Other Precautions:THIS MATERIAL SHOULD ONLY BE USED BY THOSE PERSONS
TRAINED IN THE SAFE HANDLING OF HAZARDOUS CHEMICALS. PREVENT
CONTACT W/SKIN, EYES & CLOTHING. ALL CHEMICALS SHOULD BE CONSIDERED
HAZARDOUS, DIRECT PH YSICAL CONTACT SHOULD BE AVOIDED.
============= Exposure Controls/Personal Protection =============
Other Protective Equipment:CHEMICAL RESISTANT LABORATORY COAT &/RUBBER
APRON, USE APPROPRIATE OSHA/MSMA APPROVED SAFETY EQUIPMENT.
Supplemental Safety and Health
MELTING POINT: 170.6-172.4F
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:(SEE SUPP)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN CHEMICAL INCINERATOR EQUIPPED W/AN
AFTERBURNER & SCRUBBER IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.