text
stringlengths 542
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:INNERBOND 2010 FLUID;40,000 CST
CAGE:66172
CAGE:66172
============= Composition/Information on Ingredients =============
Ingred Name:POLYDIMETHYLSILOXANE
CAS:9016-00-6
RTECS #:TQ2690000
Ingred Name:OTHER COMPONENTS (TYPE NOT SPECIFIED)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:UNKNOWN Skin:UNKNOWN Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATION OF EYES AND SKIN
POSSIBLE.LOW TOXICITY.
Explanation of Carcinogenicity:DATA PER MGF MSDS.
Effects of Overexposure:EYE:MILD DISCOMFORT;SKIN:NON-IRR;ING:LOW
TOXICITY.
Medical Cond Aggravated by Exposure:NONE EXPECTED
======================= First Aid Measures =======================
First Aid:EYES AND SKIN:FLUSH WITH LARGE AMOUNT OF WATER FOR ABOUT
15-20 MINUTES;SEEK MEDICAL ATTENTION IMMEDIATELY.INHALATION:REMOVE
TO FRESH AIR;CALL A PHYSICIAN.INGESTION:SEEK MEDICAL ATTENTION
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:572F,300C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:NONE EXPECTED
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP WITH VERMICULITE INTO A STEEL DRUM.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY WELL VENTED LOW FIRE
RISK AREA. PROTECT FROM HEAT,SHOCK,FRICTION. KEEP CONTAINERS
CLOSED.
Other Precautions:STORE AWAY FROM HEAT,MOISTURE.AVOID BREATHING
VAPORS.AVOID DIRECT/PROLONGED CONTACT WITH SKIN/EYES.WASH HANDS
THOROUGHLY AFTER HANDLING.DO NOT EAT,DRINK,SMOKE IN WORK AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL REQMNTS UNDER ORDINARY
CONDITIONS/ADEQUATE VENT.
Ventilation:LOCAL EXHAUST TO ELIMINATE MISTS/FUMES/GASES.
Other Protective Equipment:PROTECTIVE CLOTHINGS.EYE-WASH
FACILITIES,SAFETY SHOWER.
Work Hygienic Practices:AVOID CONTACT WITH EYES AND SKIN;DO NOT BREATHE
VAPORS/MIST/DUST.WASH THOROUGHLY AFTER EACH USE.
Supplemental Safety and Health
WASH HANDS THOROUGHLY AFTER AFTER EACH USE.
================== Physical/Chemical Properties ==================
HCC:V6
Melt/Freeze Pt:M.P/F.P Text:-65F,-54C
Vapor Pres:0.01
Spec Gravity:0.96
Viscosity:40000 CST
Solubility in Water:NEGL
Appearance and Odor:CLEAR,COLORLESS,PASTE-LIKE POLYMER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MINERAL ACIDS,STRONG BASE
Stability Condition to Avoid:NONE NOTED
Hazardous Decomposition Products:SILICA ON COMBUSTION
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES;DISPOSAL MUST BE IN
ACCORDANCE WITH LOCAL,STATE AND FEDERAL REGULATIONS
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CAL-2025, 1429
Preparer's Name:R.C. JENTE
CAGE:21667
CAGE:21667
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM ALKYL ETHER SULFATE. LD50:(ORAL,RAT) 10.2 G/KG
CAS:68511-39-7
Fraction by Wt: 6%
Ingred Name:ACETIC ACID, NITRILOTRI-, TRISODIUM SALT, MONOHYDRATE;
(NITRILOTRIACETIC ACID TRISODIUM SALT)
CAS:18662-53-8
RTECS #:AJ1070000
Fraction by Wt: 15%
Ingred Name:DIPROPYLENE GLYCOL, MONOMETHYL ETHER; (DIPROPYLENE GLYCOL
METHYL ETHER)
CAS:34590-94-8
RTECS #:JM1575000
Fraction by Wt: 5%
OSHA PEL:100PPM;150PPM STEL,S
ACGIH TLV:100PPM;150PPM STEL,S
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:(ACUTE) EYES: CAUSES EYE IRRITATION.
(CHRONIC) THIS PRODUCT CONTAINS NITRILOTRIACETIC ACID, WHICH HAS
BEEN DETERMINED TO CAUSE CANCER WHEN FED TO LABORATORY ANIMALS.
Explanation of Carcinogenicity:NITRILOTRIACETIC ACID TRISODIUM SALT:
GROUP 2B (IARC).
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IN CASE OF CONTACT, IMMEDIATELY FLUSH EYES WITH PLENTY
OF WATER FOR AT LEAST 15 MINUTES. CALL MD. SKIN: WASH AREA
THOROUGHLY FOR 15 MINUTES. IF IRRITATION PERSISTS, CONTACT MD.
INGEST: CALL MD I MMEDIATELY . INHAL: REMOVE TO FRESH AIR. SUPPORT
BREATHING (GIVE O*2/ARTIFICIAL RESPIRATION) .
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:PRODUCT IS NOT FLAMMABLE. USE EXTINGUISHING MEDIA
SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE AREA, CONTAIN AS MUCH SPILLED MATERIAL AS
POSSIBLE. REMOVE ANY REMAINING MATERIAL BY ABSORBING ON VERMICULITE
OR OTHER SUITABLE MATERIAL AND PLACE IN A SEALED METAL CONTAINER
FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH EYES. WASH
THOROUGHLY AFTER HANDLING. KEEP CONTAINER CLOSED.
Other Precautions:READ AND OBSERVE ALL LABELED PRECAUTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED IN NORMAL USE. NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NORMAL.
Other Protective Equipment:NOT REQUIRED IN NORMAL USE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:LIKE WATER
Vapor Density:LIKE H2O
Spec Gravity:1.12
pH:11.25
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR GREEN LIQUID WITH PINE ODOR.
Percent Volatiles by Volume:75(WT)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, STRONG OXIDIZERS.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:UNKNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:MIX WITH A FLAMMABLE SOLVENT AND INCINERATE IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PORTERSEPT MICRO-CLEAN
CAGE:50411
CAGE:50411
============= Composition/Information on Ingredients =============
Ingred Name:ALKYL (14, 50%; C12, 40%; C16, 10%) DIMETHYL BENZYL
AMMONIUM CHLORIDE
CAS:68391-01-5
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:1-DECAMINIUM, N,N-DIMETHYL-N-OCTYL-, CHLORIDE; (OCTYL DECYL
DIMETHYL AMMONIUM CHLORIDE)
CAS:32426-11-2
RTECS #:HD6520000
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:AMMONIUM, DIDECYLDIMETHYL-, CHLORIDE; (DIDECYL DIMETHYL
AMMONIUM CHLORIDE)
CAS:7173-51-5
RTECS #:BP6560000
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:1-OCTANAMINIUM, N,N-DIMETHYL-N-OCTYL-, CHLORIDE; (DIOCTYL
DIMETHYL AMMONIUM CHLORIDE)
CAS:5538-94-3
RTECS #:RG8250000
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE & CHRONIC:DIRECT EYE CONTACT CAN
CAUSE SEVERE EYE IRRITATION. REPEATED SKIN CONTACT CAN CAUSE SEVERE
IRRITATION. INHALATION OF MISTS CAN CAUSE IRRITATION TO MUCOUS
MEMBRANES. INGESTION MAY CAUSE SEVERE IRRITATION TO MOUTH, THROAT,
GASTROINTESTINAL TRACT, AS WELL AS CIRCULATORY SHOCK & RESPIRATORY
DEPRESSION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:EYES:REDNESS, TEARING. SKIN:IRRITATION SEEN AS
REDNESS. INGEST:BURNING PAIN IN MOUTH, THROAT, ABDOMEN, CIRCULATORY
SHOCK, CONVULSIONS.
Medical Cond Aggravated by Exposure:DERMATITIS.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. EYE:FLUSH W/LG AMTS OF WATER FOR
AT LST 15 MINS LIFTING UPPER & LOWER LIDS OCCAS. GET MED ATTN.
SKIN:WASH W/MILD SOAP & WATER. REMOVE CONTAM CLTHG & LAUNDER BEFORE
REUSE. IN GEST:GIVE PROMPTLY LG QTYS OF MILK, EGGWHITES/GELATIN
SOLN. IF THESE ARE NOT AVAIL, DRINK LG QTYS OF WATER. AVOID
ALCOHOL. CONT MD IMMED. NOTE TO MD:PROBABLE MUCOSAL DMG MAY
CONTRAINDICATE (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE TO BOILING
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:MOP UP OR ABSORB ON SOLID ABSORBENT & SHOVEL
INTO CONTAINERS FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
KEEP AWAY FROM FOOD & WATER SUPPLIES.
Other Precautions:OPEN DUMPING IS PROHIBITED. DO NOT REUSE EMPTY
CONTAINER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:MECHANICAL (GENERAL) VENTILATION: SUFFICIENT.
Other Protective Equipment:NOT NEEDED.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER USING PRODUCT.
Supplemental Safety and Health
FIRST AID PROC:USE OF GASTRIC LAVAGE. MEASURES AGAINST CIRCULATORY
SHOCK, RESPIRATORY DEPRESSION & CONVULSION MAY BE NEEDED. EYE PROT:
W/FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:AS WATER
Vapor Density:AS WATER
Spec Gravity:1.01 (H2O=1)
Evaporation Rate & Reference:1 (WATER=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR BLUE LIQUID W/PLEASANT SASSAFRAS ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN COMPLIANCE W/FEDERAL, STATE & LOCAL
LAWS & 40 CFR.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CATALYST 24LV
Kit Part:Y
Preparer's Name:DAVID HAAS
CAGE:0B562
CAGE:0B562
CAGE:04552
============= Composition/Information on Ingredients =============
Ingred Name:POLYGLYCOL DIAMINE
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:CORRO,BURNS,CORNEAL INJURY.PERM
IMPAIRMENT OF VISION,BLINDNESS.SKIN:CORRO,SEVERE
BURNS,BLISTERING.SKIN SENS/ALLERGIC RX-SEVERE IN CERTAIN
PEOPLE.HARMFUL IF ABSORBED THRU SKIN.INHAL:VAP IRRIT,NAU,H
EADACHE.INEST:HARMFUL,BURNS MOUTH/UPPERGASTROINTESTINAL
TRACT.CHRONIC:NONE KNOWN.
Effects of Overexposure:EYE CORRO,BURNS,CORNEAL INJURY,PERM IMPAIRMENT
OF VISION,BLINDNESS.SKIN CORR,SEVERE BURNS,BLISTERING.SKIN
SENS/ALLERGIC RX.NAU,HEADCHE.HARMFUL IF INGEST,BURNS MOUTH/UPPER GI
TRACT.
Medical Cond Aggravated by Exposure:EXPOSURE MAY AGGRAVATE PRE-EXISTING
SKIN &/OR EYE DISORDERS.
======================= First Aid Measures =======================
First Aid:EYE:IMMED FLUSH WELL W/H2O @LEAST 15MINS WHILE EYELIDS
OPN.GET IMMED MED ATTN.SKIN:IMMED FLUSH W/LOTS OF H2O WHILE REMOVE
CONTM CLOTH/SHOES.THEN WASH WELL W/SOAP/H2O.AVOID SCRUB-INCR
ABSORPT/WORSEN EF FECT.GET MED ATTN.INHAL:MOVE TO FRESH
AIR.CONSC/ALERT DIL BY GIVING H2O TO DRINK.NEVER GIVE ANYTHING BY
MOUTH IF DROWSY/UNCONSC/CONVULS.GET IMMED MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:260F,127C
Lower Limits:NE
Upper Limits:NE
Extinguishing Media:USE CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:FIREFIGHTERS/RESCUE PERSONNEL SHOULD WEAR
+PRESSURE SCBA & FULL PROT EQPMT.COOL EXPO CNTNRS W/WATER-PREVENT
PRESSURE BUILDUP.LG QUANT MATL INVOLVED (SUPPLEMENT)
Unusual Fire/Explosion Hazard:DECOMPO/COMBUST PROD MAY BE TOXIC.CLOSED
CONTAINERS MAY VIOLENTLY RUPTURE UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:RESPONSE OPERATION MUST BE CONDUCTED IAW
PROVISIONS OF 29CFR1910.120.REVIEW ENTIRE MSDS BEF PROCEEDING
W/RESPONSE.ACTIVATE AVAI EXHAU VENTI IN IMMED AREA.WIPEUP/ABSORB
W/VERMI/SIMILAR MATL.WASH AREA W /SOAPY H2O-REMOVES RESIDUE.COLLECT
ABSORBED (SUPP)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL DRY LOCATION W/ADEQU
VENTI.KEEP CNTRN TIGHTLY SEAL WHEN NOT IN USE.KEEP AWAY FRM OPN
FLAME/HEAT SOURCES.
Other Precautions:CONSULT PROD TECHN BULLETIN FOR DETAIL STORAGE INFO.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE APPROPRIATE PROPERLY FITTED RESPIRATOR IF
EXPOSURES EXCEED PEL/TLV VALUES.TYPE OF PROTECTION
SELECTED(SCBA,AIR-PURIFYING,ETC)WILL DEPEND UPON CONDITIONS OF
USE.OBSERVE OSHA REGS FOR RESPIRATORY PR OTECTION (29CFR1910.134).
Ventilation:PROVIDE SUFFI MECH EXHU VENTI-DRAW VAP/MIST/FUME FRM
PROCESSES AWAY FRM WORKER,ESPEC HI TEMP WORK.
Other Protective Equipment:PROPER CHEM-RESIST APRON,ADDN IMPERV
CLOTH.EMERG EYEWASH FACI,SAFETY SHOWER AVAI.WASH BEF
EAT/DRINK/SMOKE.
Work Hygienic Practices:DONT REUSE CONTAM CLOTH TIL PROPERLY
CLEAN.CONTAM LEATHER ART/SHOES CANT BE DECONTAM-DESTROY.WASH
HAND/FC WELL AFT HNDLG
Supplemental Safety and Health
FIREFIGHT:EVACUATE AREA,FIGHT FIRE FROM SAFE DISTANCE. DECOMPO
PRODS:WILL VARY DEPENDING ON COMBUST CONDITIONS. SPILL:MATL/WATER
RINSES IN APPROP CNTNR.DISPO OF IAW CURRENT FED/STATE/LOC
REGS.LG:LIMIT ACCESS.SHUT OFF W/O RISK.ACTIVATE VENTI.DIKE/PREVENT
ENTRY SEWER/DRAIN/WATERWAYS.COLLECT/DISPO IAW CURRENT FED/STATE/LO
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>480F,>249C
Melt/Freeze Pt:M.P/F.P Text:NP
Decomp Temp:Decomp Text:NP
Vapor Pres:<0.001
Vapor Density:>AIR
Spec Gravity:1.00
pH:NP
Evaporation Rate & Reference:NP
Solubility in Water:SOLUBLE
Appearance and Odor:AMBER LIQUID, AMINE ODOR
Percent Volatiles by Volume:ND
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS,ACIDS,BASES,EPOXIDES.
Stability Condition to Avoid:AVOID STORAGE IN OPN CNTNR,EXPO TO OPN
FLAMES,UNCNTRLD EXPO TO HEAT/UNCNTRLD MIX W/EPOXIES OR EXPO TO
INCOMPAT SUBSTANCE
Hazardous Decomposition Products:CO,CO2,OXIDES OF NITROGEN,AMINES,OTHER
ORG SUBST MAY BE FORM DURING COMBUST.CHEM NATURE/QUANT OF DECOMPO
BYPRODS(SUPPLE)
Conditions to Avoid Polymerization:UNCONTROLLED MIXING
W/AMINES,ANHYDRIDES,MERCAPTANS,IMIDAZOLES MAY CAUSE HAZ
POLYMERIZATON.
==================== Disposal Considerations ====================
Waste Disposal Methods:DOESNT CONTAIN ANY SUBSTANCES REG BY SARA SEC
313.DISPOSE OF IAW CURRENT LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
NIIN: 01-380-8503
Product ID: GAYLORD FROMULA G-510
Cage: 09051
Box: 1149
=======================================================
Contractor Summary
=======================================================
Cage: SO023
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: CLEANING COMPOUND,SOLVENT-DETERGENT
Unit of Issue: DR
Quantitative Expression: 00000000055GL
UI Container Qty: 1
=======================================================
Health Hazards Data
=======================================================
First Aid: NOT REQUIRED.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: NO PRECAUTIONS NECESSARY. WASH W/ WATER.
Waste Disposal Methods: STANDARD SEWAGE TREATMENT METHODS.
Handling And Storage Precautions: NO SPECIAL PRECAUTIONS REQUIRED.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: NONE REQUIRED
Fire Fighting Procedures: NONE REQUIRED
Unusual Fire/Explosion Hazard: NONE
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE REQUIRED
Ventilation: NONE REQUIRED
Other Protective Equipment: NONE REQUIRED
=======================================================
Physical/Chemical Properties
=======================================================
Boiling Point: =100.C, 212.F
Vapor Pres: 17.2MMHG
Vapor Density: .63 AIR=1
Spec Gravity: 8.45#WT. GAL WATER=1
PH: 9.7
Evaporation Rate & Reference: .69 BU AC=1
Solubility in Water: COMPLETE
Appearance and Odor: SLIGHTLY VISCOUS, LIGHT AMBER COLOR, MILD PLEASANT ODOR
Percent Volatiles by Volume: NONE
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE
Materials To Avoid: NONE
Hazardous Decomposition Products: NONE
Hazardous Polymerization Indicator: NO
=======================================================
Transportation Information
=======================================================
Trans ID NO: 156723
Product ID: GAYLORD FROMULA G-510
Review Date: 03/09/1999
Multiple KIT Number: 0
Unit Of Issue: DR
Container QTY: 1
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: GAYLORD FROMULA G-510
Cage: 09051
Company Name: GAYLORD INDUSTRIES INC
Street: 10900 SW AVERY ST
Zipcode: 97062-1149
Label Required IND: Y
Date Of Label Review: 04/18/2001
Status Code: A
Origination Code: G
=======================================================
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:RP SUPER FILTER COAT, 414 BULK CONCENTRATE
CAGE:82866
CAGE:82866
============= Composition/Information on Ingredients =============
Ingred Name:SOLUBLE HYDROCARBON OIL
= Wt:97.
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:POLYETHYLENE
CAS:9002-88-4
RTECS #:KX3270000
= Wt:2.
Ingred Name:METHYLPARABEN; (METHYL PARABEN)
CAS:99-76-3
RTECS #:DH2450000
= Wt:1.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ROUTE(S) OF ENTRY: INHALATION: AVOID
BREATHING VAPORS OR FUMES. SKIN: AVOID CONTACT WITH EYES AND SKIN.
INGESTION: DO NOT SWALLOW. ACUTE & CHRONIC. NOT APPLICABLE.
Effects of Overexposure:SWALLOWING MAY CAUSE VOMITING OR DIARRHEA.
Medical Cond Aggravated by Exposure:NOT APPLICABLE.
======================= First Aid Measures =======================
First Aid:INHALATION: GET TO FRESH AIR IF INHALED. EYES: IF CONTACT IS
MADE WITH EYES, IMMEDIATELY AND THOROUGHLY FLUSH WITH WATER FOR AT
LEAST 15 MINUTES. SKIN: THOROUGHLY WASH WITH SOAP AND WATER.
INGESTION:DO NOT INDUCE VOMITING; CALL PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:=179.4C, 355.F
Extinguishing Media:"B" CLASS EXTINGUISHER.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . HANDLE AS HYDROCARBON OIL. COOL EXPOSED CONTAINERS WITH
WATER SPRAY. AVOID BREATHING VAPORS AND FUMES.
Unusual Fire/Explosion Hazard:BURNS AS OIL.
================== Accidental Release Measures ==================
Spill Release Procedures:TREAT AS WATER SOLUBLE HYDROCARBON OIL - FLUSH
WITH WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT FREEZE OR SUBJECT TO HIGH
TEMPERATURES. STORE AT 60F-90F. DO NOT HANDLE OR STORE NEAR HEAT,
SPARKS, FLAME, OR STRONG OXIDANTS.
Other Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMALLY NOT NEEDED. USE AIR SUPPLIED
RESPIRATORY PROTECTION IN CONFINED OR ENCLOSED AREAS.
Ventilation:LOCAL EXHAUST: USE IN WELL-VENTILATED AREA. MECHANICAL
(GENERAL): N/A. SPECIAL: PROVIDE GREATER THAN 60 FPM HOOD/FACE
VELOCITY FOR CONFINED SPACES. OTHER: N/A.
Other Protective Equipment:ANSI APPROVED EYE WASH AND DELUGH SHOWER .
USE CHEMICAL-RESISTANT APRON OR OTHER CLOTHING IF NEEDED TO AVOID
PROLONGED SKIN CONTACT.
Supplemental Safety and Health
PHYSICAL CHARACTERISTICS: ODOR THRESHOLD: N/A.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NOT APPLIC
Melt/Freeze Pt:M.P/F.P Text:NOT APPLIC
Spec Gravity:0.94 (H*2O = 1)
Evaporation Rate & Reference:N/A (BUTYL ACETATE =1)
Solubility in Water:COMPLETELY WATER SOLUBLE
Appearance and Odor:AMBER COLOR-BLAND ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:SMOKE, CARBON MONOXIDE, AND SULFUR
OXIDES IN THE CASE OF INCOMPLETE COMBUSTION.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:HANDLE AS LOCAL CODES DICTATE FOR SOLUBLE OIL.
DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ACTIVATOR C
CAGE:0JVX9
CAGE:0JVX9
============= Composition/Information on Ingredients =============
Ingred Name:BENZYLAMINE, N,N-DIMETHYL-; (BENZYLDIMETHYLAMINE).
(LD50:(ORAL,RAT) 265 MG/KG.
CAS:103-83-3
RTECS #:DP4500000
Fraction by Wt: 90-100%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPP DATA:ALLOWED LOCALLY.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:MD. KEEP PATIENT ABSOLUTELY QUIET & START
OXYG INHAL THRU SUITABLE EQUIP. IF BRTHG HAS STOPPED/IS (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:LABORED GIVE ASSISTED RESP. INGEST:SEEK MED ATTN
IMMED. REMOVE STOM CONTENTS BY GASTRIC SUCTION/INDUCE (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:VOMIT ONLY AS DIRECTED BY MED PERS. NEVER GIVE
ANYTHING BY MOUTH TO UNCON PERS. NOTE TO MD:THIS PROD IS (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:HIGHLY INJURIOUS TO ALL TISS, SIMILAR TO THAT OF
AMMONIA GAS, CHEM PNEUM, PULM EDEMA, LARYNGEAL EDEMA & (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:DELAYED SCARRING OF AIRWAY/OTHER AFFECTED TISS MAY
OCCUR FOLLOWING EXPOS. THERE IS NO SPECIFIC TREATMENT. (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:CLINICAL MANAGEMENT IS BASED ON SUPPORTIVE TREATMENT
WHICH IS SIMILAR TO THAT FOR THERMAL BURNS.
RTECS #:9999999ZZ
Ingred Name:EYE PROT:& FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE CONT:CAN CAUSE SEV IRRIT & BURNS.
BURNS MAY CAUSE BLINDNESS. SKIN CONT:CAN CAUSE SEV IRRIT, PAIN &
BURNS. INHAL:TOX. INHAL OF VAPS MAY SEVERELY DMG TISS & ORGS OF
RESP TRACT W/POSS FATAL RSLTS. IN GEST:TOX. MAY CAUSE HDCH, NAUS,
VOMIT/DEATH UNLESS TREATED PROMPTLY. TOX INFO:RPTD &/OR PRLNG EXPOS
MAY(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:RSLT IN: ADVERSE RESP EFTS (SUCH AS
COUGH, TIGHTNESS OF CHEST/SHORTNESS OF BREATH); ADVERSE SKIN EFTS
(SUCH AS DEFAT, RASH/IRRIT); ADVERSE EYE EFTS (SUCH AS CONJ/CORNEAL
DMG). NOTE:DUE TO PRO D'S PHYSICAL COMPOSITION, RELS/GENERATION OF
DUST IS NOT EXPECTED TO OCCUR UNDER NORMAL CNDTNS OF USE.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN, EYE & RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYES:HOLD LIDS APART & IMMED FLUSH W/PLENTY OF WATER FOR AT
LST 15 MINS. SEEK MED ATTN IMMED. SKIN:REMOVE PROD & IMMED FLUSH
AFFECTED AREA W/WATER FOR AT LST 15 MINS. EXCEPT IN MOST MINOR,
SUPERFICIAL & LOCALIZED BURNS, COVER AFFECTED AREAW/STERILE
DRESSING/CLEAN SHEETING & TRANSPORT FOR MED CARE. DO NOT APPLY
GREASE/OINTMENTS. CONSULT MD. INHAL:MOVE PATIENT AT ONCE TO FRESH
AIR & CALL (ING 3)
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:129F,54C
Extinguishing Media:USE ALCOHOL FOAM, DRY CHEMICAL OR CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . IGNITION WILL GIVE RISE TO A CLASS B FIRE. COOL FIRE
EXPOSED CONTAINERS W/WATER SPRAY.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP LEAK, IF POSS. VENT SPACE INVOLVED. SHUT
OFF/REMOVE ALL IGNIT SOURCES. CONSTRUCT DIKE TO PVNT SPREADING. IF
RECOVER IS NOT FEASIBLE, ADMIX W/DRY SOIL &/OR NON-REACTIVE ABSORB
& PLACE IN CNTNR/DUM PSTER PENDING DISP. FLUSH AREA W/WATER
(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM OXIDIZERS, HEAT/FLAMES.
KEEP IN COOL, DRY, VENTED STOR & IN CLSD CNTNRS. STORE AWAY FROM
IGNIT SOURCES. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:GROUND ALL CNTNRS DURING TRANSFER. AVOID BRTHG VAPS.
HANDLE IN WELL VENTED WORK SPACE. SMOKING IN AREA IS PROHIBITED.
RMOVE ALL EQUIP WHICH MAY BE SOURCE OF IGNIT FROM VICINITY WHILE
HNDLG. FOR INDUS USE ONLY! PVNT CONT W/SKIN & EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN POORLY VENTILATED AREAS, A NIOSH APPROVED
CARTRIDGE MASK FOR ORGANIC VAPORS IS RECOMMENDED.
Ventilation:ADEQUATE GENERAL & LOCAL EXHAUST. MAINTAIN CONCENTRATIONS
BELOW ESTABLISHED TLVS.
Other Protective Equipment:ANSI APPRVD EYE WASH FOUNTAIN & DELUGE
SHOWER . OTHER PROT CLTHG AS NEC. A SLICKER SUIT & RUBBER BOOTS ARE
REC.
Work Hygienic Practices:WHEN HANDLING, DO NOT EAT, DRINK OR SMOKE.
CONTACT LENSES SHOULD NOT BE WORN.
Supplemental Safety and Health
PH:ALKALINE. HAZ DECOMP PROD:BE PRDCD AT ELEVATED TEMPS. SPILL
PROC:SPRAY. CLEAN-UP PERS MUST BE EQUIPPED W/NIOSH APPRVD SCBA &
BUTYL RUBBER PROT CLTHG. WASTE DISP METH:DEPENDING ON QUALITY & QTY
OF W ASTE TO BE TREATED, TREATMENT PLANT CAPABILITY & DISCHARGE
WATER QUALITY STDS. DISP OF IN APPRVD LANDFILL IF (ING 2)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:360F,182C
Vapor Pres:1.8 @ 77C
Vapor Density:4.7
Spec Gravity:0.9
pH:SUPDAT
Evaporation Rate & Reference:<1
Solubility in Water:SLIGHT
Appearance and Odor:COLORLESS LIQUID; SLIGHT AMMONIACAL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, CLEANING SOLUTIONS SUCH AS CHROMERGE OR AQUA REGIA.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
AMMONIA, NITROGEN OXIDES MAY BE PRDCD WHEN PROD IS HEATED. IRRIT
TOX FUMES MAY (SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY W/ALL FEDERAL, STATE & LOC REGS. INCIN IN
ADMIXTURE W/FUEL EQUIPPED W/SCRUBBER TO REMOVE NITROGEN OXIDES. TO
REMOVE CARBON MONOXIDE, CHEM &/OR BIOLOGICAL DEGRADATION IS
FEASIBLE. SUITABLE INDUS /MUNICIPAL WASTE TREATMENT SYS CAN BE
USED(SUPDAT)
| 1 | gloves_mandatory |
=======================================================
Product ID: POLYESTER PHENOLIC RESIN, 9637
Cage: 08800
=======================================================
Contractor Summary
=======================================================
Cage: 08800
Box: 1404
=======================================================
Ingredients
=======================================================
Cas: 64742-95-6
RTECS #: WF3400000
(152C); VP: <10 @ 20C; VAP DENS: 4.3
% Wt: 10-30
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
-----------------------------
Cas: 1330-20-7
RTECS #: ZE2100000
3.6; LD50 (ORAL RAT): 4300 MG/KG
% Wt: 19.6
OSHA PEL: 100 PPM
ACGIH TLV: 100 PPM/150STEL
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 100-41-4
RTECS #: DA0700000
3.66; LD50 (ORAL RAT): 3500 MG/KG
% Wt: 4.1
OSHA PEL: 100 PPM
ACGIH TLV: 100 PPM/125STEL
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 64742-94-5
RTECS #: WF3100000
VAP DENS: 4
% Wt: 1-5
OSHA PEL: 10 PPM (MFR)
ACGIH TLV: 10 PPM (MFR)
------------------------------
Cas: 111-76-2
RTECS #: KJ8575000
20C; VAP DENS: 4.1; LD50 (ORAL RAT): 1480 MG/KG
% Wt: 3.8
OSHA PEL: 50 PPM, S
ACGIH TLV: 25 PPM, S
------------------------------
Cas: 50-00-0
RTECS #: LP8925000
MG/KG
% Wt: <0.030
OSHA PEL: SEE 1910.1048
ACGIH TLV: C 0.3 PPM, A2
EPA Rpt Qty: 100 LBS
DOT Rpt Qty: 100 LBS
------------------------------
Cas: 554-13-2
RTECS #: OJ5800000
% Wt: <0.009
OSHA PEL: 15 PPM (MFR)
ACGIH TLV: 10 PPM (MFR)
------------------------------
Cas: 95-63-6
RTECS #: DC3325000
% Wt: 4.7
OSHA PEL: 25 PPM
ACGIH TLV: 25 PPM
------------------------------
Cas: 98-82-8
RTECS #: GR8575000
% Wt: 1.1
OSHA PEL: 50 PPM, S
ACGIH TLV: 50 PPM, S
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
MONITOR FOR 24 HRS, OBSERVE & SUPPORT
-----------------------------
STOMACH IN A WAY WHICH AVOIDS ASPIRATION.
-----------------------------
AREA.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: SEE INGREDIENTS.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: INGEST: VOMIT, NAUS & DIARR. MAY CAUSE SEV DMG
OF GI TRACT. ASPIR CAN BE HAZ IF SWALLOWED. MAY CAUSE PULM EDEMA. SKIN: MOD
IRRIT. MAY CAUSE DEFAT W/PRLNG EXPOS. CAN DRY SKIN. INHAL: EXCESS INHA L
CAUSES HDCH, DIZZ, NAUS & INCOORD. CAUSES IRRIT OF MOUTH, NOSE &
THROAT. CAN CAUSE UNCON IF INHALED. (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: EYE: IRRIT, REDNESS &
TEARING, BLURRED VISION. CHRONIC: DERM, RESP AILMENTS, CNS DMG, LIVER &
KIDNEY DMG, CORNEAL DMG, BLOOD DISORDERS, REPRO DISORDERS. CONTAINS A
COMPONENT THAT IS TERATOGE N. EYE DMG. REPORTED TO CAUSE EMBRYOTOXICITY WHEN
TESTED ON SOME LAB ANIMALS. MAY CAUSE DEVEL OF TISS MASSES (SUP DAT)
Medical Cond Aggravated By Exposure: RESPIRATORY AND PULMONARY DISORDERS;
LIVER, KIDNEY AND DERMAL AILMENTS; CENTRAL NERVOUS SYSTEM DISORDERS;
GASTROINTESTINAL DISORDERS; BLOOD DISORDERS; EYE AILMENTS.
First Aid: INGEST: DO NOT INDUCE VOMIT. SLOWLY DILUTE W/1-2 GLASSES OF
WATER/MILK & SEEK MED ATTN. NEVER GIVE ANYTHING BY MOUTH TO AN UNCON
PERS. SKIN: REMOVE CONTAM CLTHG & LAUNDER BEFORE REUSE. WASH W/SOAP &
W ATER. GET MED ATTN IF IRRIT PERSISTS. INHAL: REMOVE TO FRESH AIR. IF NOT
BRTHG GIVE ARTF RESP, PREF MOUTH-TO-MOUTH. IF BRTHG IS DFCLT GIVE OXYGEN. GET
MED ATTN. EYES: IMMED FLUSH W/PLENTY OF
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: WIPE, SCRAPE/SOAK UP IN INERT MATL & PUT IN CONTR
FOR DISP. WASH WALKING SURF W/DETERGENT & WATER TO REDUCE SLIPPING HAZ.
WEAR PROPER PROT EQUIP AS SPECIFIED IN PROT EQUIP SECTION. REMOVE SOURCES OF
I GNIT. WARN OTHER WORKERS OF SPILL. (ING13)
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS.
Handling And Storage Precautions: USE GROUND STRAP. STORE UPRIGHT IN COOL PLACE
BELOW 30C (85F). KEEP CONTAINER CLOSED WHEN NOT IN USE. AVOID BREATHING
VAPORS.
Other Precautions: IF EXPOSED TO HIGH VAP CONC, LEAVE AREA AT ONCE. AVOID CONT
W/SKIN & EYES. OPEN CONTR CAUTIOUSLY. USE ONLY IN WELL-VENTD AREA.
WARNING! FLAMM. DO NOT INHALE VAPS. KEEP AWAY FROM FOOD & SMKNG MATLS. AV
OID CONT W/EYES.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point Text: 85.0F,29.4C
Lower Limits: 0.6%
Upper Limits: 7.0%
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER MIST.
Fire Fighting Procedures: WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). VAPORS MAY FORM EXPLOSIVE MIXTURE W/AIR. FLAMMABLE.
EVACUATE AREA & FIGHT FIRE FROM SAFE DISTANCE.
Unusual Fire/Explosion Hazard: SENSITIVITY TO STATIC DISCHARGE IS EXPECTED;
MATERIAL HAS A FLASH POINT BELOW 200F.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE IN A WELL-VENTILATED AREA. USE NIOSH APPROVED
RESPIRATORY PROTECTION IF TLV EXCEEDED OR OVEREXPOSURE IS LIKELY. CARTRIDGE
RESPIRATOR.
Ventilation: EXHAUST VENTILATION. USE IN WELL-VENTILATED AREA. MECHANICAL
VENTILATION.
Other Protective Equipment: EMERGENCY EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA (FP N). RUBBER APRON.
Work Hygienic Practices: WASH HANDS BEFORE EATING AND SMOKING.
Supplemental Safety and Health: EFTS OF OVEREXP: THRU LONG TERM EXPOS. ANIMAL
STUDIES CLEARLY DEMONSTRATED DOSE-RELATED ADVERSE EFTS ON CNS, HEMATOPOIETIC
TISS, BLOOD, KIDNEY & LIVER, ASSOC W/ADMIN OF ETHYLENE GLYCOL MONOBUTYL
ETHER (EGBE) (EXTRACTED FROM DHHS (NIOSH) PUBLICATION #90-118) (FP N).
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 289F,143C
Vapor Pres: SEE INGS
Vapor Density: SEE INGS
Spec Gravity: 0.97 (H*2O=1)
Solubility in Water: MODERATE
Appearance and Odor: AMBER LIQUID, AROMATIC ODOR
Percent Volatiles by Volume: 52(WT)
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: KEEP AWAY FROM HEAT, SPARKS, AND FLAME.
Materials To Avoid: AVOID CONTACT WITH ACIDIC, BASIC OR OXIDIZING AGENTS. METAL
SALTS SUCH AS ALUMINUM CHLORIDE.
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE, TOXIC FUMES,
TOXIC METAL FUMES, FUMES OF AROMATIC HYDROCARBONS, XYLENE FUMES.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: POLYESTER PHENOLIC RESIN, 9637
Cage: 08800
Company Name: INSULATING MATERIALS INC
Street: 1 CAMPBELL RD
PO Box: 1404
Zipcode: 12306-9701
Label Required IND: Y
Date Of Label Review: 08/18/1997
Status Code: C
Label Date: 08/18/1997
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE LIQUID. ACUTE: INGEST: VOMIT, NAUS &
DIARRHEA. MAY CAUSE SEV DAMAGE OF GI TRACT. ASPIR CAN BE HAZ IF SWALLOWED.
MAY CAUSE PULM EDEMA. SKIN: MOD IRRIT. MAY CAUSE DEFATTING W/PRLNG EXPOS. CAN
DRY SKIN. INHAL: EXCESS INHAL CAUSES HEADACHE, DIZZ, NAUS &
INCOORDINATION. CAUSES IRRIT OF MOUTH, NOSE & THROAT. CAN CAUSE UNCON IF
INHALED. EYE: IRRIT, REDNESS, TEARING, BLURRED VISION. CHRONIC: DER M, RESP
AILMENTS, CNS, LIVER & KIDNEY DAMAGE, CORNEAL DAMAGE & REPRODUCTIVE
DISORDERS. ANIMAL STUDIES HAVE SHOWN DOSE-RELATED ADVERSE EFTS ON CNS,
BLOOD-FORMING TISSUE, BLOOD, LIVER & KIDNEY, ASSOCIAT ED W/ADMINISTRATION
OF 2-BUTOXYETHANOL (FP N).
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CHLOROFORM, F23
CAGE:IO841
CAGE:IO841
CAGE:8Y898
============= Composition/Information on Ingredients =============
Ingred Name:CHLOROFORM; (TRICHLOROMETHANE)(SARA III)
CAS:67-66-3
RTECS #:FS9100000
OSHA PEL:50 PPM, C
ACGIH TLV:10 PPM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:SUPP DATA: DELAYED LUNG INJURY. CAN CAUSE DELAYED ADVERSE
HLTH AFFECTS. CAN CAUSE FEELING OF DISORIENTATION. (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2: EXTENDED OVEREXP TO VAPS &/DUST CAN CAUSE EYE
INJURY. TARGET ORGANS- LIVER, KIDNEYS, HEART.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: WASH CONTAMD CLTHS. IF PATIENT IS
EXHIBITING SIGNS OF SHOCK-KEEP WARM & QUIET. INDUCE VOMITING (ING
5)
RTECS #:9999999ZZ
Ingred Name:ING 4: IF INGESTED. CONTACT POISON CONTROL CNTR IMMED IF
NEC. DO NOT ADMIN LIQUID/INDUCE VOMIT TO AN UNCON (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: OR CONVULSING PERS. IF PATIENT IS VOMITING-WATCH
CLOSELY TO MAKE SURE AIRWAY DOES NOT BECOME OBSTRUCTED(ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: BY VOMIT. GET MED ATTN IF NECESSARY. AND ANTIDOTE IS
A SUBSTANCE INTENDED TO COUNTERACT THE EFT OF A (ING *8)
RTECS #:9999999ZZ
Ingred Name:ING 7: A POISON. IT SHOULD BE ADMIN ONLY BY MD/TRAINED EMER
PERS. MED ADVICE CAN BE OBTAINED FROM POISON CNTROL CNTR.
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORA,RAT) 908 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:CONT LENSES SHOULD NOT BE WORN IN
LABS. ALL CHEMS SHOULD BE CONSIDERED HAZ-AVOID DIRECT PHYSICAL
CONT! SUSPECTED CARCIN - MAY PRDC CANCER. EXPOS CAN CAUSE
NAUS,HDCH, DIZZ &/VOMIT. POSS MUTAGEN-MAY CAU SE BIRTH DEFECTS IN
FUTURE GENERATIONS.MAY BE FATAL IF INHAL! MAY BE FATAL/CAUSE
BLINDNESS IF INGEST.(EFTS OF OVEREXP)
Explanation of Carcinogenicity:CHLOROFORM: IARC MONO, SUPP, VOL 7 PG
152,1987: GROUP 2B. NTP 7TH ANNUAL RPT ON CARCINOGEN, 1994 ANTIC TO
BE CARCIN.
Effects of Overexposure:HLTH HAZ: MAY BE FATAL IF INGEST. CAN CAUSE EYE
& SKIN IRRIT. DUST &/VAPS CAN CAUSE IRRIT TO RESP TRACT. CAN BE
IRRIT TO MUC MEMBS. PRLGD EXPOS MAY CAUSE NAUS/HDCH/DIZZ/&/EYE DMG.
CAN CAUSE CNS INJURY . EXPOS CAN CAUSE LIVER DMG. EXPOS CAN CAUSE
KIDNEY DMG. CAN CAUSE CVS INJURY. VAPS &/DIRECT (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH EYES CONTINUOUSLY W/WATER FOR 15-20 MINS. SKIN:
FLUSH WITH WATER FOR 15-20 MINS. IF NO BURNS HAVE OCCURRED-USE SOAP
& WATER TO CLEANSE SKIN. INHAL: REMOVE TO FRESH AIR. ADMIN O*2 IF
PATIENT IS HAVING DFCLTY BRTHG. IF PATIENT HASSTOPPED BRTHG ADMIN
ARTF RESP. IF PATIENT IS IN CARDIAC ARREST ADMIN CPR. CONTINUE LIFE
SUPPORTING MEASURES UNTIL MED ASSIST HAS ARRIVED. REMOVE & (ING 4)
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:NO EXPLOSION LIMITS ARE AVAILABLE FOR THIS
COMPOUND. USE MEDIA SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:NO FIRE OR EXPLOSION HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:EVAUATE AREA. WEAR APPROPRIATE NIOSH/MSHA
APPRVD EQUIP. VENT AREA. ABSORB ON VERMICULITE/SIMILAR MATL. SEEP
UP & PLACE IN AN APPROPRIATE CNTNR. HOLD FOR DISP. WASH CONTAMD
SURFACES TO REMOVE ANY RESID UES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE ONLY IN HOOD. AVOID CONTACT
WITH SKIN, EYES & CLOTHING. KEEP TIGHTLY CLOSED IN A COOL DRY
PLACE. STORE ONLY W/COMPATIBLE CHEMICALS.
Other Precautions:PRODUCT IS FURNISHED FOR LAB USE ONLY! OUR PRODS MAY
NOT BE USED AS DRUGS, COSMETICS, AGRICULTURAL/PESTICIDAL PRODS,
FOOD ADDITIVES/AS HOUSEHOLD CHEMS. PERSONS NOT SPECIFICALLY &
PROPERLY TRAINED SHOU LD NOT HANDLE THIS CHEM/ITS CNTNR.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:SHOULD BE HANDLED ONLY IN A HOOD.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:EYE CONT CAN CAUSE SEVERE EYE BURNS. CAN CAUSE SKIN
BURNS. MAY BE FATAL IF ABSORB THRU SKIN! VAPS CAN CAUSE SEVERE EYE
INFLAMM & SWELLING OF ADJOINING TISS. CAN CAUSE SENSIT BY SKIN CO
NT. MAY BE RAPIDLY ABSORBED THRU SKIN W/POTNTL ADVERSE HLTH EFTS.
CAN CAUSE ALLERGIC RESP RXN. CAN CAUSE (ING 2)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:141F,61C
Melt/Freeze Pt:M.P/F.P Text:145F,63C
Vapor Pres:160 @ 20C
Vapor Density:4.1
Spec Gravity:1.492
Evaporation Rate & Reference:11.6 (BUAC=1)
Solubility in Water:VERY SLIGHTLY
Appearance and Odor:COLORLESS LIQUID W/FRUITY/PLEASANT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES. DO NOT USE MAGNESIUM/ALUMINUM/THEIR ALLOYS AS CNTNRS.
POWDERED METALS, ACTIVE METALS(E.G.SODIUM),CAUSTICS.
Stability Condition to Avoid:SENSITIVE TO LIGHT. AIR SENSITIVE.
SENSITIVE TO HEAT.
Hazardous Decomposition Products:DECOMPOSITION LIBERATES TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED W/AN
AFTER BURNER & SCRUBBER. DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE
& FEDERAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HP C4195A-IMAGING DRUM CARTRIDGE
Preparer's Name:NOT PROVIDED
CAGE:18660
CAGE:18660
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM ALLOY
Minumum % Wt:95.
Maxumum % Wt:98.
Other REC Limits:NONE
OSHA PEL:NONE
ACGIH TLV:NONE
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Minumum % Wt:.5
Maxumum % Wt:2.
Other REC Limits:NOT PROVIDED
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:BINDER RESIN
Minumum % Wt:.5
Maxumum % Wt:2.
Other REC Limits:NONE
OSHA PEL:NONE
ACGIH TLV:NONE
Ingred Name:ORGANIC SEMICONDUCTOR
Minumum % Wt:.3
Maxumum % Wt:.8
Other REC Limits:NONE
OSHA PEL:NONE
ACGIH TLV:NONE
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT PROVIDED
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:POTENTIAL HEALTH EFFECTS: EYE EFFECTS:
NOT APPLICABLE UNDER INTENDED USE. SKIN EFFECTS: UNLIKELY TO CAUSE
SKIN IRRITATION UNDER NORMAL USE CONDIOTIONS. INGESTION EFFECTS:
NOT AN PPLICABLE ROUTE OF ENT RY FOR INTENDED USE. INHALATION
EFFECTS: NOT AN PPLICABLE ROUTE OF ENTRY FOR INTENDED USE. CHRONIC
EFFECTS: NONE KNOWN.
Explanation of Carcinogenicity:NOT A KNOWN OR SUSPECTED CARCINOGEN
ACCORDING TO ANY IARC MONOGRAPH, NTP, OSHA REGULATIONS (USA) OR
PROPOSITION 65 (CALIFORNIA).
Effects of Overexposure:NONE
Medical Cond Aggravated by Exposure:NOT PROVIDED
======================= First Aid Measures =======================
First Aid:AFTER INHALATION: NOT APPLICABLE. AFTER INGESTION: NOT
APPLICABLE. AFTER CONTACT WITH SKIN: IN CASE OF IRRITATION, WASH
SKIN WITH SOAP AND WATER. AFTER CONTACT WITH EYES: NOT APPLICABLE.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, DRY CHEMICAL. FOAM OR WATER.
Fire Fighting Procedures:IF FIRE OCCURS IN THE PRINTER, TREAT AS AN
ELECTRICAL FIRE--DO NOT EXTINGUISH WITH WATER OR FOAM.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:NO ADVISE ON SAFE HANDLING AND
PROTECTION AGAINST FIRE. MAINTAIN STORAGE TEMPERATURE LESS THAN
45C.
Other Precautions:NOT PROVIDED
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER NORMAL CONDITIONS.
Ventilation:NOT PROVIDED
Other Protective Equipment:NOT REQUIRED UNDER NORMAL CONDITIONS.
Work Hygienic Practices:NOT PROVIDED
Supplemental Safety and Health
THIS PRODUCT IS AN IMAGING DEVICE FOR THE COLOR LASERJET 4500, 4500N,
4500DN PRINTER.
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NOT RELEVANT
Melt/Freeze Pt:=100.C, 212.F
M.P/F.P Text:OR HIGHER
Decomp Temp:Decomp Text:NOT PROVIDED
Spec Gravity:NO DATA AVAILABLE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORED ALUMINUM CYLINDER, ODORLESS, GREENISH-BLUE
COLOR
Corrosion Rate:NOT PROVIDED
================= Stability and Reactivity Data =================
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
=================== Toxicological Information===================
Toxicological Information:NO DATA AVAILABLE.
===================== Ecological Information =====================
Ecological:NO INFORMATION INDICATING ANY ADVERSE ECOLOGICAL EFFECTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:PRODUCT/UNUSED PRODUCT/CONTAMINATED PACKAGING
(FOR GERMANY ONLY) RECOMMENDATION: CONSULTATION WITH THE DISPOSAL
AGENCY AND THE RELEVANT AUTHORITIES.
=================== MSDS Transport Information ===================
Transport Information:INTERNATIONAL TRANSPORT INFORMATION: UN NUMBER:
NONE. UN SHIPPING NAME: NONE. HAZARD CLASS: NONE. PACKING GROUP:
NONE. SPECIAL PRECAUTIONS: NONE.
===================== Regulatory Information =====================
SARA Title III Information:CHEMICALS REQUIRED TO REPORT UNDER SARA
TITLE III SECTION 313 (USA): NONE.
Federal Regulatory Information:NOT PROVIDED
State Regulatory Information:CHEMICALS REQUIRED TO REPORT UNDER
CALIFONIA PROPOSITION 65 (USA): NONE.
======================= Other Information =======================
======================================================================
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:A15030
CAGE:JO882
CAGE:54590
CAGE:JO882
============= Composition/Information on Ingredients =============
Ingred Name:THORIUM 232
CAS:7440-29-1
RTECS #:XO6400000
===================== Hazards Identification =====================
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
======================= First Aid Measures =======================
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
===================== Fire Fighting Measures =====================
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
================== Accidental Release Measures ==================
======================Handling and Storage ======================
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
SOURCE OF DATA-MIL HANDBOOK 600-1 SEP 76.SAFETY & HEALTH DATA DEVELOPED
BY DGSC-STF.
================== Physical/Chemical Properties ==================
HCC:A3
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-IN ACCORDANCE WITH
DOD REGULATIONS AND FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:O-S-801E CLASS 3,SULFURIC ACID
Preparer's Name:J.J.BURGARD
CAGE:82925
CAGE:82925
CAGE:49859
============= Composition/Information on Ingredients =============
Ingred Name:SULFURIC ACID (SARA III)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 37.1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 62.9%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS UNKNOWN.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: SEVERE BURNS TO EYES AND SKIN.
INHALATION: MIST WILL IRRITATE RESPIRATORY TRACT (LUNGS, THROAT)
AND POSSIBLY LEAD TO COMPLICATIONS. TOXIC BY INHALATION. INGESTION:
MAY CAUSE SEVERE BURNS TO MOU TH, THROAT, AND STOMACH. CHRONIC: MAY
CAUSE DENTAL EROSION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SEVERE IRRITATION OR BURNS TO EYES, NOSE, AND
THROAT. IRRITATION OF RESPIRATORY TRACT (LUNGS, THROAT). SEVERE
BURNS TO MOUTH, THROAT, AND STOMACH. DENTAL EROSION.
Medical Cond Aggravated by Exposure:OPEN WOUNDS AND SORES. RESPIRATORY
AILMENTS SUCH AS EMPHYSEMIA AND BRONCHITIS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
FLUSH AREA WITH LARGE AMOUNTS OF WATER. GET MEDICAL ATTENTION.
INHALATION: MOVE TO FRESH AIR. IF ADVERSE SYMPTOMS DEVELOP, GET
MEDICAL ATTENTION. INGESTION: DRINK LARGE AMOUNTS OF WATER. DO NOT
INDUCE VOMITING. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NO FIRE HAZARD. USE MEDIA SUITABLE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SCBA. COOL FIRE EXPOSED CONTAINERS WITH WATER. DO NOT
PERMIT WATER TO CONTACT ACID.
Unusual Fire/Explosion Hazard:MAY CAUSE FIRE WHEN IN CONTACT WITH
ORGANIC MATERIALS. WILL ATTACK SOME METALS RELEASING FLAMMABLE AND
EXPLOSIVE HYDROGEN; TO BE DISPERSED WITH VENTING.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE CLOTHING. STOP LEAK IF IT CAN BE DONE WITHOUT RISK.
CONTAIN AND ZONE OFF CONTAMINATED AREA. NEUTRALIZE WITH SODA ASH OR
LIME. ABSORB WITH NE UTRAL MATERIAL. SCOOP INTO DRUMS FOR DISPOSAL.
Neutralizing Agent:SODA ASH OR LIME.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE ONLY IN APPROVED CONTAINERS.
AVOID ROUGH HANDLING OF DRUMS. VENT DRUMS WEEKLY. EYE WASH STATION
AND SAFETY SHOWER SHOULD BE NEARBY.
Other Precautions:"NO SMOKING" REGULATIONS MUST BE INFORCED BECAUSE OF
POSSIBLE PRESENCE OF HYDROGEN. DO NOT GET IN EYES, ON SKIN, ON
CLOTHING. DO NOT BREATHE VAPORS. KEEP IN TIGHTLY CLOSED
CONTAINERS.LOOSEN CLOSURES C AUTIOUSLY.USE WITH ADEQUATE
VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION EXIST.
IF AIRBORNE CONCENTRATION EXCEEDS TLV, A NIOSH APPROVED
SELF-CONTAINED BREATHING APPARATUS IS RECOMMENDED.
Ventilation:USE MECHANICAL (GENERAL) OR LOCAL EXHAUST VENTILATION TO
MEET TLV REQUIREMENTS.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:535F,279C
Vapor Pres:<0.5
Spec Gravity:1.8354
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR TO SLIGHTLY TURBID; OFF WHITE TO STRAW COLOR.
USUALLY ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALINE MATERIALS, SALTS OF OTHER ACIDS, HYDRATED MATERIALS,
COMBUSTIBLE AND ORGANIC MATERIALS.
Stability Condition to Avoid:EXCESSIVE HEAT. ADDITION OF WATER CAUSES
LARGE TEMPERATURE INCREASE.
Hazardous Decomposition Products:IF HEATED SUFFICIENTLY, SULFUR
DIOXIDE, SULFUR TRIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS. WASTE MAY QUALIFY AS HAZARDOUS WASTE UNDER
RCRA. SPILLED MATERIAL MAY BE REPORTABLE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:A60G1 GREEN BLEND A COLOR TONER
CAGE:09800
CAGE:09800
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL
CAS:107-21-1
RTECS #:KW2975000
Minumum % Wt:10.
Maxumum % Wt:30.
ACGIH STEL:C127 MG/M3;C50 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
= Wt:71.
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
= Wt:8.
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE IRRITATION TO
EYES, SKIN & UPPER RESPIRATORY SYSTEM. BURNING SENSATION MAY
INDICATE EXCESSIVE EYE/SKIN EXPOSURE. PROLONGED OVEREXPOSURE TO
SOLVENTS MAY CAUSE ADVERSE EFFECTS TO THE LIVER & URINARY SYSTEMS.
Effects of Overexposure:IRRITATION, HEADACHE, NAUSEA, DIZZINESS,
REDNESS, ITCHING, BURNING
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE, RESTORE BREATHING. KEEP
WARM & QUIET. SKIN: WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH
W/LARGE AMOUNTS OF WATER FOR 15 MINS. INGESTION: NEVER GIVE
ANYTHING BY MOUTH IF UNCONSCIOUS. GIVE CONSCIOUS PATIENT SEVERAL
GLASSES OF WATER. IF VOMITING IS NOT SPONTANEOUS, INDUCE VOMITING
BY HAVING THE PATIENT GENTLY TOUCH THE BACK OF HIS THROAT W/A
FINGER. KEEP AIRWAY CLEAR . OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>92.8C, 199.F
Extinguishing Media:CO2, DRY CHEMICAL, ALCOHOL FOAM
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIPMENT W/SELF CONTAINED
BREATHING APPARATUS. WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS
USED, FOG NOZZLES ARE PREFERABLE. WATER MAY BE USED TO COOL CLOSED
CONTAINERS TO PREVENT PRESSURE BUILDUP & POSSIBLE
AUTOIGNITION/EXPLOSION.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE DUE TO THE
BUILDUP OF PRESSURE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE &
REMOVE W/INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
TRANSFER ONLY TO APPROVED CONTAINERS W/COMPLETE & APPROPRIATE
LABELING. USE W/ADEQUATE VENTILATION.
Other Precautions:DON'T TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
AVOID BREATHING VAPOR & SPRAY MIST. AVOID CONTACT W/SKIN & EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, WEAR A PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESPIRATOR APPROVED BY NIOSH/MSHA FOR PROTECTION.
WHEN SANDING/ABRADING THE DR IED FILM, WEAR A DUST/MIST RESPIRATOR
APPROVED BY NIOSH/MSHA FOR DUST GENERATED FROM THIS PRODUCT,
UNDERLYING PAINT/THE ABRASIVE.
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF
EXPOSURE IS MAINTAINED BELOW APPLICABL EXPOSURE LIMITS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE. WASH HANDS AFTER USING.
Supplemental Safety and Health
TO MINIMIZE EXPOSURE, FOLLOW RECOMMENDATIONS FOR PROPER USE,
VENTILATION & PERSONAL PROTECTIVE EQUIPMENT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212-388F
Vapor Density:>1
Spec Gravity:1.32-2.22
pH:7.0-7.5
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:25-62
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:BY FIRE: CO2, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DON'T
INCINERATE CLOSED CONTAINER. DISPOSE OF IN ACCORDANCE W/LOCAL,
STATE & FEDERAL REGULATIONS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:QUEST FLYING MODEL ROCKET MOTORS
CAGE:GO523
CAGE:GO523
============= Composition/Information on Ingredients =============
Ingred Name:PYROTECHNIC IGNITER COMPOSITION
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:FLOOD W/WATER IF A SMALL NUMBER OF MOTORS ARE
INVOLVED.
Fire Fighting Procedures:DON'T USE SUFFOCATION METHODS-DEVICES CONTAIN
THEIR OWN OXYGEN. LARGE NUMBER OF MOTORS PREVENT THE SPREAD OF FIRE
& ALLOW THEM TO BURN.
Unusual Fire/Explosion Hazard:MOTORS MAY FLY ABOUT IN THE EVENT OF A
FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:NO SMOKING/OPEN FLAMES IN VICINITY . CAREFULLY
PICK UP & PLACE ITEMS IN CARDBOARD CARTON. SWEEP UP ANY EXPOSED
CHEMICAL COMPOSITION W/A NATURAL FIBER BRUSH.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID OPEN FLAMES, SMOKING & HIGH
TEMPS >120F. KEEP SHIPPING CARTONS COOL & DRY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:SLIGHT
Appearance and Odor:ALL PYROTECHNIC COMPOSITION IS CONTAINED IN A
CARDBOARD CASING.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER
Stability Condition to Avoid:OPEN FLAMES, TEMP >120F & OTHER IGNITION
SOURCES.
Hazardous Decomposition Products:SMOKE, NITROGEN OXIDES & SULFUR OXIDES
MAY BE PRODUCED IN A FIRE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:LACQUER C/N-GLOSS ORANGE 12197 ID 786202
Preparer's Name:W. A. ELLISON
CAGE:61196
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SOLVENT) (SARA 313) (VAPOR PRESSURE 22 MM HG @
20C) (LFL 1.7 / UFL 7.1)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 20%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ISOPROPYL ALCOHOL (SOLVENT) (VAPOR PRESSURE 33 MM HG @ 20C)
(LFL 3.0 / UFL 13.0)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:400 PPM/STEL 500 PPM
ACGIH TLV:400 PPM/STEL 500 PPM
Ingred Name:ISOBUTYL ALCOHOL (SOLVENT) (VAPOR PRESSURE 10 MM HG @ 20C)
(LFL 1.0 / UFL 11.0)
CAS:78-83-1
RTECS #:NP9625000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENE (SOLVENT) (SARA 313) (VAPOR PRESSURE 5 MM HG @ 20C)
(LFL 1.0 / UFL 7.0)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/STEL 150 PPM
ACGIH TLV:100 PPM/STEL 150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE (SARA 313) (VAPOR PRESSURE 1 MM HG @ 20C)
(LFL 1.0 / UFL 6.7) (SKIN)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: < 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/STEL 125 PPM
ACGIH TLV:100 PPM/STEL 125 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:NITROCELLULOSE (RESIN)
CAS:9004-70-0
RTECS #:QW0970000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
Ingred Name:ISOBUTYL ACETATE (SOLVENT) (LFL 2.0 / UFL 11.0)
CAS:110-19-0
RTECS #:AI4025000
Fraction by Wt: 15%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM/700 MG/M3
ACGIH TLV:150 PPM/700 MG/M3
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CHROMIUM III OXIDE (PIGMENT) (SARA 313)
CAS:1308-38-9
RTECS #:GB6475000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.5 MG/M3
ACGIH TLV:0.5 MG/M3
Ingred Name:LEAD CHROMATE (SARA 313) (PIGMENT)
CAS:7758-97-6
RTECS #:GB2975000
Fraction by Wt: < 1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.05 MG/M3/0.10 CEIL
ACGIH TLV:0.0120 MG/M3
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE (PIGMENT)
CAS:14464-46-1
RTECS #:VV7325000
Fraction by Wt: < 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.05 MG/M3 RDUST9293
Ingred Name:TALC (PIGMENT)
CAS:14807-96-6
RTECS #:MW2700000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:2 PPM/20 MPPCF
ACGIH TLV:2 PPM/15 MPPCF
Ingred Name:SILICA, CRYSTALLINE
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: < 1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:DI(2-ETHYLHEXYL)PHTHALATE (ADDITIVE) (SARA 313)
CAS:117-81-7
RTECS #:TI0350000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:VOC: 6.07 (GRAMS/LITER)
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INGEST: GASTROINTESTINAL IRRITATION,
NAUSEA AND VOMITING. ASPIRATION OF MATERIAL INTO LUNG: CHEMICAL
PNEUMONITIS. INHAL: NOSE OR THROAT IRRITATION. ACUTE CNS DEPRESSION
W/HEADACHES, DIZZINESS, NAUSEA, CONFUSION. EYE: IRRITATION. SKIN:
IRRITATION AND DEFATTING.
Explanation of Carcinogenicity:THERE IS SUFFICIENT EVIDENCE OF
CARCINOGENICITY OF DI(2-ETHYLHEXYL)PHTHALATE (DEHP).
Effects of Overexposure:SILICOSIS-LUNG CANCER-LIVER-KIDNEY-BLOOD
INJURY/DAMAGE-SEVERE DAMAGE TO BLOOD
FORMING-NERVOUS-URINARY-REPRODUCTIVE SYS. APPETITE LOSS-METAL
TASTE(MOUTH)-ANXIETY-CONSTIPATION-NAUSEA-WEAK-INSOMNIA-HEADA
CHE-MUSCLE/JOINT PAIN-FINE
TREMORS-NUMB-DIZZY-HYPERACTIVITY-COLIC-PERM BRAIN/NERV SYS DAMAGE.
KIDNEY-LUNG-SPLEEN DAMAGE
Medical Cond Aggravated by Exposure:NOTE TO PHYSICIAN: ANY TREATMENT
THAT MIGHT BE REQUIRED FOR OVEREXPOSURE SHOULD BE DIRECTED AT THE
CONTROL OF SYMPTOMS AND THE CLINICAL CONDITIONS.
======================= First Aid Measures =======================
First Aid:INGEST: DO NOT INDUCE VOMITING. CALL POISON CONTROL CENTER,
HOSPITAL EMERGENCY ROOM OR DR IMMED. INHAL: REMOVE TO FRESH AIR
IMMED. IF BREATHING STOPPED, GIVE ARTIFICIAL RESP. KEEP
WARM/QUIET-GET MED A ID IMMED. EYE: FLUSH W/WTR-15 MINS, LIFTING
LIDS OCCASIONALLY. GET MED AID. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH AFFECTED AREA WITH SOAP AND WATER. OBTAIN MEDICAL ATTENTION IF
IRRITATION PERSISTS.
===================== Fire Fighting Measures =====================
Flash Point:40.0F,4.4C
Autoignition Temp:Autoignition Temp Text:572F
Lower Limits:1.0%
Upper Limits:13.0%
Extinguishing Media:NFPA CLASS B FIRE EXTING (CO2-ALL PURPOSE DRY
CHEM-ALCOHOL FOAM) MADE TO EXTING FLAMM LIQ FIRES. POLYMER FOAM-LG
FIRES
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE-USE TO COOL EXPOSED
CONTAINER-PREVENT PRESSURE BUILDUP/AUTO EXPLOSION WHEN EXPOSED TO
EXTREME HEAT. FOG NOZZLES PREFERRED WITH WATER
Unusual Fire/Explosion Hazard:EMERGENCY CONDITIONS-OVEREXPOSURE TO
DECOMPOSITION PRODUCTS MAY BE HEALTH HAZARD-SYMPTOMS DELAYED.
OBTAIN MEDICAL ATTENTION. WARNING] FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVAC AREA-ELIM IGNIT SRCS. DIKE AND CONTAIN
WITH INERT MATL-TRANS LIQ TO COVERED METAL CNTNR. USE NON-SPARK
TOOL. DISPOSE ABSORB DIKING MATL IN COVERED METAL CNTNR. PREVENT
CONTAM OF SEWER-STREAM-GROU NDWATER WITH SPILLED MATERIAL OR USED
ABSORBENT
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 115F (46C). STORE
LARGE QUANTITIES IN COMPLIANCE WITH OSHA 29CFR1910.106
Other Precautions:DO NOT INGEST-CLOSE CNTNR AFTER USE-DONT BREATHE
DUST. EMPTY CNTNRS MUST NOT BE WASHED OR RE-USED FOR ANY PURPOSE.
GROUND/BOND CNTNRS TO RECEIVING CNTNR. DO NOT WELD-BRAZE-CUT ON
EMPTY CNTNR-NEVER USE PRESS TO EMPTY-DRUM NOT A PRESS VESSEL
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SEE OSHA 29CFR1910.1025(LEAD) WELL VENT-RESP NOT
REQ. RESTRICT VENT-ORGANIC VAPOR RESP REQ. SPRAY-MECH PREFILTER
ALSO REQ. CONFINE-AIR SUPPLY RESP REQ. ABOVE TLV-RESP W/APPROP
PROTECT FACTOR. SEE OSHA 29CFR1910.134/RESP PROTECT-MANUAL(AIHA)
Ventilation:LOCAL EXHST-SUFFICIENT VOL/PATTRN TO MAINTAIN EXPOS BELOW
NUSIANCE DUST LIMITS/PEL. SEE OSHA 29CFR1910.1025 FOR REQ
Other Protective Equipment:EYEWASH STATION, SAFETY SHOWER
Work Hygienic Practices:WASH HANDS AND FACE THOROUGHLY BEFORE EATING OR
DRINKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:203-288F
Melt/Freeze Pt:M.P/F.P Text:-50F,-46C
Vapor Pres:33 @ 68F
Vapor Density:> THAN AIR
Spec Gravity:1.1
pH:4-7STD
Viscosity:> 200 CST
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Solubility in Water:SLIGHT IN WATER
Appearance and Odor:LIQUID, SOLVENT ODOR
Percent Volatiles by Volume:70
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT (>115F (46C) AND
SOURCES OF IGNITION
Hazardous Decomposition Products:BURNING W/HEAT BY WELD/CUT PRODUCES
SMOKE-CO-CO2. OXIDES OF NITROGEN/CHROMIUM/LEAD GENERATED. POSSIBLE
METAL FUME FEVER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORD W/FEDERAL-STATE-LOCAL LAWS AND
REGULATIONS. INCINERATE ONLY IN EPA FACILITY. DO NOT INCINERATE
CLOSED CNTNRS. OBSERVE PRECAUTIONS FOR DISPOSAL OF FLAMM MATL. MAY
DISPOSE CONTAMINATED ABSORB IN HAZARDOUS WASTE LANDFILL. RCRA:
D001
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PROPYLENE GLYCOL
Resp. Party Other MSDS Num.:00414-0010-101280
CAGE:TO530
CAGE:TO530
CAGE:001W1
Contract Num:SP0450-01-M-D915
CAGE:1KH20
============= Composition/Information on Ingredients =============
Ingred Name:1,2-PROPANEDIOL
CAS:57-55-6
RTECS #:TY2000000
Minumum % Wt:98.
Maxumum % Wt:100.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:UNKNOWN Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:UNKNOWN OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION-MAY CAUSE TRANSIENT
IRRITATION IF INHALED AS AN AEROSOL. SKIN-CONTACT WOULD BE EXPECTED
TO CAUSE TRANSIENT REDNESS IF NOT WASHED OFF & LEFT ON THE SKIN FOR
AN EXTENED PERIOD OF TIME.EYE-CONTACT WOULD BE EXPECTED TO CAUSE
TRANSIENT REDNESS IF NOT WASHED OUT & LEFT IN THE EYE FOR AN
EXTENDED PERIOD OF TIME. NO CORNEAL INVOLVEMENT OR VISUAL
IMPAIRMENT IS EXPECTED. INGESTION- INGEST ION MAY CAUSE IRRITATION
OF THE GASTROINTESTINAL TRACT & GASTROINTESTINAL DISCOMFORT.
CHRONIC: THERE ARE NO KNOWN OR REPORTED EFFECTS FROM CHRONIC
EXPOSURE EXCEPT FOR EFFECTS SIMILAR TO THOSE EXPERIEN CED FROM
ACUTE EXPOSURE..
Explanation of Carcinogenicity:THIS PRODUCT IS NOT KNOWN OR REPORTED TO
BE CARCINGENIC BY ANY REFERENCE SOURCE INCLUDING IARC, NTP, OSHA OR
EPA. THE CARCINOGENICITY HAS BEEN EVALUATED THROUGH ANIMAL STUDY &
IT WAS FOUND NOT TO BE C ARCINOGENIC.
Effects of Overexposure:INGESTION: INGESTION MAY CAUSE IRRITATION OF
THE GASTROINTESTINAL TRACT & GASTROINTESTINAL DISCOMFORT WITH ANY
OR ALL OF THE FOLLOWING SYMPTOMS: NAUSEA, VOMITING, LETHARGY, OR
DIARRHEA.
Medical Cond Aggravated by Exposure:NONE KNOWN OR REPORTED.
======================= First Aid Measures =======================
First Aid:INHALATION: IF INHALED: REMOVE INDIVIDUAL TO FRESH AIR. SKIN:
IF ON SKIN: FLUSH SKIN WITH WATER FOR 15 MINUTES. CALL A PHYSICIAN
IF IRRITATION DEVELOPS. EYES: IF IN EYES: FLUSH EYES WITH PLENTY OF
WAT ER FOR AT LEAST 15 MINUTES. CALL A PHYSICIAN IF IRRITATION
DEVELOPS. INGESTION: IF SWALLOWED: IMMEDIATELY DRINK WATER TO
DILUTE. CONSULT A PHYSICIAN IF SYMPTOMS DEVELOP. NEVER GIVE
ANYTHING BY MOUTH T O AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:=107.C, 224.6F
Autoignition Temp:=371.C, 699.8F
Lower Limits:2.6
Upper Limits:12.5
Extinguishing Media:USE ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL OR
WTER SPRAY WHEN FIGHTING FIRES.
Fire Fighting Procedures:IN CASE OF FIRE, USE NORMAL FIRE FIGHTING
EQUIPMENT INCLUDING A NIOSH APPROVED SELF-CONTAINED BREATHING
APPARATUS (SCBA). USE WATER TO COOL CAONTAINERS.WATER OR FOAM MAY
CAUSE FROTHING IF LIQUID SOLVE NT OR OIL IS BURNING BUT IT STILL
MAY BE USEFUL EXTINGUISHING AGENT IF CAREFULLY APPLIED TO THE FIRE.
Unusual Fire/Explosion Hazard:MATERIAL MAY BE IGNITED ONLY IF PREHEATED
TO HIGH TEMPERATURES, FOR EXAMPLE IN A FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:LAND RELEASE-CREATE A DIKE OR TRENCH TO
CONTAIN MATERIALS. ABSORB SPILL WITH INERT MATERIAL (E.G., DRY
SAND, CLAY, EARTH OR COMMERCIAL ABSORBENT), THEN PLACE IN A
CHEMICAL WASTE CONTAINER. DECOMTAMINA TE ALL CLOTHING AND THE
SPILLA REA USING A DETERGENT AND FLUSH WITH LARGE AMOUNTS OF WATER.
CONTAIN ALL CONTAMINATED WATER FOR DISPOSAL AND/OR TREATMENT.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLING-DO NOT TAKE INTERNALLY. AVOID
CONTACT WITH SKIN, EYES AND CLOTHING. UPON CONTACT WITH SKIN OR
EYES, WASH OFF WITH WATER. AVOID BREATHING MIST OR VAPOR.
STORAGE-STORE IN A COOL, DRY AND WELL V ENTILATED PLACE. ISOLATE
FROM INCOMPATIBLE MATERIALS. DO NOT STORE AT TEMPERATURES ABOVE- 49
C/120F.
Other Precautions:WASTE DISPOSAL SUMMARY-IF THIS PRODUCT BECOMS A
WASTE, IT DOES NOT MEET THE CRITERIAA OF A HAZARDOUS WASTE AS
DEFINED UNDER 40 CF 261, IN THTAT IT DOES NOT EXHIBIT THE
CHARACTERISTICS OF HAZARDOUS WAS TE OF SUBPART C, NOR IS IT LISTED
AS A HAZARDOUS WASTE UNDER SUBPART D.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATORY PROTECTION NOT NORMALLY NEEDED SINCE
VOLATILITY AND TOXICITY ARE LOW. IF VAPORS, MISTS OR SEROSOLS ARE
GENEREATED, WEAR A NIOSH APPROVED RESPIRATOR. NIOSH APPROVED AIR
PURIFYING RESPIRATOR WITH ORGANIC VAPOR CARTRIDGE AND DUST/MIST
FILTER. AIR PURIFYING RESPIRATORS SHOULD NOT BE USED IN OXYGEN
DEFICIENT OR PUBLISHED LIMIT.
Ventilation:LOCAL EXHAUST VENTILATION IS RECOMMENDED IF VAPORS, MISTS
OR AEROSOLS ARE GENERATED. OTHERWISE, USE GENERAL EXHAUST
VENTILATION.
Other Protective Equipment:PROTECTIVE CLOTHING TYPE: NEOPRENE.
Work Hygienic Practices:FOLLOW GOOD INDUSTRIAL HYGIENE PRACTICES.
Supplemental Safety and Health
VENTILATION: NO EXPOSURE LIMITS EXISTS FOR THE CONSTITUENTS OF THIS
PRODUCT. NO ENGINEERING CONTROLS ARE LIKELY TO BE REQUIRED TO
MAINTAIM OPERATOR COMFORT UNDER NORMAL CONDITIONS OF USE. *MSDS NO:
00 414-010-101280. SYNONYMS: PG; METHYL ETHYLENE GLYCOL;
1,2-DIHYDROXYPROPANE. CHEMICAL FAMILY: GLYCOLS. FORMULA: C3H6O2.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:=187.2C, 369.F
Vapor Pres:<0.1
Vapor Density:2.62
Spec Gravity:1.04
pH:NA
Appearance and Odor:CLEAR COLORLESS LIQUID, MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:STABLE UNDER NORMAL CONDITIONS. AVOID HIGH
TEMPERATURES. PRODUCT MAY BE UNSTABLE AT TEMPERATURES ABOVE:
218C/425F.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:PRODUCT ANIMAL TOXICITY: ORAL LD50 VALUE
(RAT)>5 G/KG. DERMAL LD50 VALUE(RABBIT)>2 G/KG. SKIN IRRITATION:
THIS MATERIAL IS EXPECTED TO BE SLIGHTLY IRRITATING. EYE
IRRITATION: THIS MATERIAL IS EXPECTED TO BE SLIGHTLY IRRITATING.
REPRODUCTIVE AND DEVELOPMENTAL TOXICITY: NO REPRODUCTIVE OR
DEVELOPMENTAL RISK TO HUMANS IS EXPECTED FROM EXPOSURE TO THIS
PRODUCT. DEVELOPMENTAL TOXICITY: COMPONENT DATA:
1,2-PROPANEDIOL-THIS CHEMICAL HAS BEEN TESTED IN LABORATORY ANIMALS
& NO EVIDENCE OF TERATOGENICITY, EMBRYOTOXICITY OR FETOTOXICITY WAS
SEEN. MUTAGENICITY: COMPONENT DATA: 1,2-PROPANEDIOL-THIS MATERIA L
HAS BEEN SHOWN NOT TO BE MUTAGENIC B
===================== Ecological Information =====================
Ecological:ECOLOGICAL TOXICITY VALUES: 1,2-PROPANEDIOL-GOLDFISH 24 HR.
LC50:>5000 MG/L(MEASURED, STATIC). RAINBOW TROUT (SALMOGAIRDNERI)
LETHAL DOSE (24 HR EXPOSURE)>50000 MG/L (NOMINAL, STATIC). BRINE
SHRIMP 2 4 HR. LC50: >10000 MG/L (NOMINAL, STATIC). DAPHINE MAGNA,
48 HR EC50:>10000 MG/L (NOMINAL, STATIC).
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL METHODS-AS A NONHAZARDOUS LIQUID WASTE,
IT SHOULD BE DISPOSED OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS BY INCINERATION. COMPONENTS SUBJECT TO LAND BAN
RESTRICTIONS: NO COMPO NENTS SUBJECT TO LAND BAN RESTRICTIONS.
POTENTIAL US EPA WASTE CODES: NOT APPLICABLE.
=================== MSDS Transport Information ===================
Transport Information:THIS MATERIAL IS NOT REGULATEDAS A DOT HAZARDOUS
MATERIAL. DOT DESCRIPTION (49 CFR 172.101): LAND (U.S. DOT): NOT
REGULATED. AIR (IATA/ICAO): NOT REGULATED. WATER (IMO)) NOT
REGULATED. FLASHPOINT:? NO T APPLICABLE.
===================== Regulatory Information =====================
SARA Title III Information:SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT
(SARA) TITLE III: HAZARD CATEGORIES SECTION 311/312 (4 CFR 370.2):
HEALTH-NONE, PHYSICAL: NONE. EMERGENCY PLANNING & COMMUNITY RIGHT
TO KNOWN (40 CFR 355, APP. A): EXTREMELY HAZARDOUS SUBSTANCES
SECTION 302-THRESHOLD PLANNING QUANTITY: NOT APPLICABLE. REPORTABLE
QUANTITY (40 CFR 302.4): NONE LISTED. SUPPLIER NOTIFICATION
REQUIREMENTS (40 CFR 372.45), 31 3 REPORTABLE COMPONENTS: NO 313
LISTED CHEMICALS IN THIS PRODUCT. CLEAN AIR ACT SOEMI: PROPYLENE
GLYCOL. CLEAN AIR ACT VOC SECTION 111: PROPYLENE GLYCOL.
Federal Regulatory Information:TOXIC SUBSTANCE CONTROL ACT (TSCA): THE
COMPONENTS OF THIS PRODUCT ARE LISTED ON THE TSCA INVENTORY OF
EXISTINMG CHEMICAL SUBSTANCES. PESTCIDE ACCEPTANCE INDICATION: US
EPA REGISTRATION NUMBER: NOT AP PLICABLE.
State Regulatory Information:PENNSYLVANIS: 1,2-PROPANEDIOL. NEW JERSEY:
NOT LISTED. MASSACHUSETTES: NOT LISTED.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:521-04 NEUTRAL BASE, SILATHANE INT/EXT (SUPDAT)
CAGE:EO376
CAGE:EO376
CAGE:85520
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 25-50%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (MAGNESIUM
SILICATE)
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 0-5%
OSHA PEL:20 MPPCF
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC; (HYDROCARBON
SOLVENT)
CAS:64742-88-7
Fraction by Wt: 0-5%
Other REC Limits:1050 MG/M3 (MFR)
OSHA PEL:2625 MG/M3 (MFR)
ACGIH TLV:525 MG/M3 (MFR)
Ingred Name:PIGMENTS
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC CONTENT RANGE:3.32 TO 3.74
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:EXPLOSIVELY. CNTNRS EXPOSED TO INTENSE HEAT FROM
FIRES SHOULD BE COOLED W/WATER TO PVNT VAPOR PRESSURE (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:BUILDUP WHICH COULD RESULT IN CONTAINER RUPTURE.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:INDUCE VOMITING UNLESS ADVISED BY A
PHYSICIAN. CALL A PHYSICIAN IMMEDIATELY.
RTECS #:9999999ZZ
Ingred Name:SPILL RELEASE PROC:AUTHORITIES. NOTIFY HLTH & POLLUTION
CONTROL AGENCIES. CALL SPILL RESPONSE TEAMS IF SPILL IS LARGE.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:PARTICULATE & GAS & VAPOR. IN CONFINED AREAS, USE
(NIOSH APPRVD) AIR LINE TYPE RESPIRATORS/HOODS. (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:RESP PROT MAY ALSO BE NEC IN ANY LATER MFG
OPERATIONS IN WHICH THESE PRODS MAY BECOME AIRBORNE IN FORM (ING
12)
RTECS #:9999999ZZ
Ingred Name:ING 11:OF VAPOR OR DUST.
RTECS #:9999999ZZ
Ingred Name:VENT:APPRVD RESP TO PVNT OVEREXPOSURE. PROVIDE GEN
DILUTION/LOC EXHAUST VENT IN VOL & PATTERN TO KEEP TLV (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:OF THE MOST HAZ INGRED IN SECTION II BELOW
ACCEPTABLE LIMIT, LEL IN SECTION IV BELOW STATED LIMIT AND (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:TO REMOVE DECOMPOSITION PRODUCTS DURING WELDING OR
FLAME CUTTING ON SURFACES COATED WITH THESE PRODUCTS.
RTECS #:9999999ZZ
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:THESE PRODUCTS MAY CAUSE NOSE,
THROAT AND EYE IRRITATION. SYMPTOMS OF OVEREXPOSURE INCLUDE
DIZZINESS, HEADACHE, INTOXICATION WITH EUPHORIA LEADING TO
UNCONSCIOUSNESS. CHRONIC:REPORTS HAVE ASSOCI ATED REPEATED &
PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN & NERVOUS SYSTEM (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:DMG. INTENTIONAL MISUSE BY DELIB
CONCENTRATING & INHALING CONTENTS MAY BE HARMFUL/FATAL. DO NOT
BREATHE VAPORS/SPRAY MIST. WEAR APPROP, PROPERLY FITTED RESP (NIOSH
APPRVD) DURING & AFTER APPL IC UNLESS AIR MONITORING DEMONSTRATES
VAP/MIST LEVS ARE BELOW APPLIC LIMS. FOLLOW RESP MFR'S DIRECTIONS
FOR RESP USE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/LUKE WARM WATER FOR @ LEAST 15 MINS. SEEK PHYS
IMMED. SKIN:FLUSH WASH W/COPIOUS AMTS OF LUKE WARM WATER. REMOVE
CONTAMD CLTHG PROMPTLY. IF IRRIT OCCURS, GET MED ATTN. INHAL:REMOVE
EXPOSED INDIVIDUAL TO FRESH AIR. RESTORE BRTHG IF REQD. CONT PHYS
IMMED. INGEST:RINSE MOUTH IMMED. GIVE EXPOSED INDIVIDUAL 6-8 OUNCES
OF LIQ. (NEVER GIVE ANYTHING BY MOUTH TO UNCON PERSON.) DO NOT (ING
8)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:104F,40C
Lower Limits:0.9%
Upper Limits:7.0%
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE . THE NFPA
CLASS B EXTING IS DESIGNED TO EXTING NFPA CLASS IB FLAMM LIQ FIRES.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER SPRAY MAY BE INEFTIVE. WATER MAY BE USED TO COOL
CLSD CNTNRS TO PVNT PRESS BUILDUP (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPKS & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. DO NOT APPLY TO HOT (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:STOP AND/OR CONTAIN DISCHARGE IF IT MAY BE
DONE SAFELY. KEEP ALL SOURCES OF IGNIT AWAY. VENTILATE AREA OF
SPILL. USE NON-SPARKING TOOLS FOR CLEANUP. COVER W/INERT MATL TO
REDUCE FUMES. KEEP OUT OF DRA INS, SEWERS, OR WATERWAYS. CONTACT
FIRE(ING 9)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. GROUND CNTNRS
WHEN POURING & LIMIT FREE-FALL TO FEW INCHES TO PREVENT STATIC
SPARKS. KEEP CNTNR TIGHTLY CLSD WHEN NOT IN USE.
Other Precautions:AVOID SPONT COMBUST OF CONTAMD RAGS/OTHER EASILY
IGNITABLE ORGANIC MATLS BY IMMED IMMERSION IN WATER. EMPTIED CNTNRS
MAY CNTN HAZ PROPERITES. DO NOT CUT/PUNCTURE CNTNR. DO NOT WELD
NEAR CNTNR. USE ONL Y WITH ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN OUTDOOR/OPEN AREAS, USE (NIOSH APPRVD) MECH
FILTER RESP TO REMOVE SOLID AIRBORNE PARTICLES OF OVERESPRAY DURING
SPRAY APPLIC. IN RESTRICTED VENT AREAS, USE (NIOSH APPRVD)
CHEM-MECH FILTERS DESIGNEDTO REMOVE COMBINATION OF (ING 11)
Ventilation:USE VENT AS REQD TO CONTROL VAP CONCS. AVOID PRLNGD/RPTD
BRTHS OF VAPS. IF EXPOSURE EXCEEDS TLV, USE NIOSH (ING 13)
Other Protective Equipment:APRON SHOULD BE WORN TO AVOID SKIN CONTACT.
ANSI APPRVD EMERGENCY EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:WASH HANDS THORO BEFORE EATING & USING
WASHROOM. REMOVE CONTAMD CLTHG IMMED & DO NOT WEAR IT UNTIL
PROPERLY LAUNDERED.
Supplemental Safety and Health
MFR TRADE NAME/PART NO:BRUTONE INTERIOR ALKYD SEMI-GLOSS ENAMEL. %
VOLAT:50.96-57.73. FIRE FIGHT PROC:& POSS AUTOIGNIT/EXPLO WHEN
EXPOSED TO EXTREME HEAT. IF WATER IS USED, FOG NOZZ ARE PREF. EXPLO
HA Z:SURFACES. NEVER USE WELDING/CUTTING TORCH ON/NEAR CNTNR (EVEN
EMPTY) BECAUSE PROD (EVEN RESIDUE) MAY IGNITE (ING 6)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:2 @ 68F
Vapor Density:HVR/AIR
Spec Gravity:1.04-1.32
Evaporation Rate & Reference:SLOWER/BUTYL ACETATE
Solubility in Water:NOT KNOWN
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID EXPOSURE TO SPARKS, OPEN FLAME, HOT SURFACES & ALL SOURCES OF
HEAT & IGNITION.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY PRDCE HAZ FUMES WHEN HEATED TO
DECOMP AS IN WELDING. FUMES MAY CONTAIN CO, CO*2 & OXIDES OF
NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT FLUSH TO SEWER, WATERSHED OR WATERWAY.
DISPOSE OF THESE PRODUCTS IN ACCORDANCE WITH APPLICABLE LOCAL,
COUNTY, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SE 861 2122 JACK OIL 15022 (24/1 QUART)
CAGE:75273
CAGE:75273
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENT REFINED MEDIUM NEUTRAL (MINERAL OIL,PETROLEUM
DISTILLATES,SOLVENT-REFINED HEAVY PARAFFINIC)
CAS:64741-88-4
RTECS #:PY8040500
Other REC Limits:5 MG/M3 MIST
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED SKIN CONTACT MAY CAUSE
DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:N/K .SKIN:PROLONGED SKIN CONTACT MAY CAUSE
DERMATITIS (SKIN IRRITATION).INGESTION/INHALATION:N/K .
======================= First Aid Measures =======================
First Aid:EYES:IMMEDIATELY FLUSH WITH WATER FOR AT LEAST 15
MINUTES.CALL PHYSICIAN.SKIN:WASH THOROUGHLY WITH SOAP AND
WATER.INGESTION:CONTACT PHYSICIAN IMMEDIATELY.INHALATION:REMOVE TO
FRESH AIR.SUPPORT BREATHI NG (GIVE O*2/ARTIFICIAL RESPIRATION) .
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>375F,190.5C
Extinguishing Media:DRY CHEMICAL,CO*2,FOAM OR WATER FOG.DO NOT USE
WATER EXCEPT AS FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .DO NOT USE WATER EXCEPT AS FOG.
Unusual Fire/Explosion Hazard:HAZARDOUS DECOMPOSITION PRODUCTS:CARBON
MONOXIDE AND CARBON DIOXIDE.
================== Accidental Release Measures ==================
Spill Release Procedures:TRANSFER BULK OF MIXTURE INTO ANOTHER
CONTAINER.ABSORB RESIDUE WITH AN INERT MATERIAL SUCH AS EARTH,SAND
OR VERMICULITE.SWEEP UP AND DISPOSE AS SOLID WASTE IN ACCORDANCE
WITH LOCAL,STATE AND FEDERAL R EGULATIONS.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT HANDLE OR STORE AT TEMPERATURES
OVER 38C,100.4F.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Other Protective Equipment:NONE
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING.
Supplemental Safety and Health
ROUTES OF ENTRY:INHALATION/SKIN/INGESTION .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>625F,329C
Melt/Freeze Pt:M.P/F.P Text:-35F,-37.2C
Decomp Temp:Decomp Text:N/K
Vapor Pres:0 MMHG
Vapor Density:NOT VOLAT
Spec Gravity:0.88 (WATER=1)
Evaporation Rate & Reference:0 (BUTYL ACETATE=1)
Solubility in Water:0% @ 20C,68F
Appearance and Odor:GREEN LIQUID WITH PETROLEUM OIL ODOR.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS SUCH AS HYDROGEN PEROXIDE,BROMINE AND CHROMIC ACID.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE
FROM BURNING.
Conditions to Avoid Polymerization:EXCESSIVE HEAT,FORMATION OF OIL
MIST.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RED LION RED GREASE II 74404
CAGE:REDLI
CAGE:REDLI
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM DISTILLATES (NAPHTHA OR RUBBER SOLVENT)
CAS:8002-05-9
RTECS #:SE7449000
Fraction by Wt: >75%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM; 8990
Ingred Name:ADDITIVES
Fraction by Wt: <25%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: HEADACHE, DIZZINESS &
DROWSINESS. EYE: IRRITATION. SKIN: IRRITATION & DERMATITIS.
INGESTION: GASTROINTESTINAL DISTURBANCES, NAUSEA, VOMITING &
DIARRHEA.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: HEADACHE, DIZZINESS & DROWSINESS.
EYE: IRRITATION. SKIN: IRRITATION & DERMATITIS. INGESTION:
GASTROINTESTINAL DISTURBANCES, NAUSEA, VOMITING & DIARRHEA.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/WATER FOR AT LEAST 15 MINUTES. IF IRRITATION
PERSISTS, SEEK MEDICAL AID. SKIN: WASH CONTACT AREA THOROUGHLY
W/SOAP & WATER. INHALATION: MOVE FROM SOURCE OF VAPOR/FUMES.
INGESTION: SEEK ME DICAL AID.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>400F
Extinguishing Media:DRY CHEMICAL, CO2, WATER, FOAM
Fire Fighting Procedures:USE WATER TO COOL CONTAINERS, STRUCTURES & TO
PROTECT PERSONNEL. WATER/FOAM MAY CAUSE FROTHING. FIREFIGHTERS MAY
NEED TO WEAR POSITIVE SUPPLIED/SCBA.
Unusual Fire/Explosion Hazard:EMPTY CONTAINERS MAY RETAIN PRODUCT
RESIDUE INCLUDING FLAMMABLE/EXPLOSIVE VAPORS. DON'T CUT, DRILL,
GRIND/WELD ON/NEAR FULL, PART FULL OR EMPTY DRUM.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB ON FIRE RESISTANT ABSORBENT. PLACE IN
PROPERLY LABELED NON-LEAKING CONTAINERS FOR PROPER DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM FLAMES, SPARKS & HOT
SURFACES. KEEP CONTAINERS CLOSED. SHELF LIFE IS 1 YEAR.
Other Precautions:DON'T WEAR CONTAMINATED CLOTHING. WASH SKIN
THOROUGHLY AFTER HANDLING. CLEAN EMPTY CONTAINERS PROPERLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NEEDED UNDER ORDINARY USE.
Ventilation:NORMAL ROOM VENTILATION IS ADEQUATE AT AMBIENT
TEMPERATURES.
Other Protective Equipment:OIL RESISTANT APRON
Work Hygienic Practices:DON'T WEAR CONTAMINATED CLOTHING. WASH
THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Density:12
Spec Gravity:0.8
Solubility in Water:NEGLIGIBLE
Appearance and Odor:RED GEL, W/OIL ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:OXIDES OF CARBON, UNIDENTIFIED
ORGANICS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AT AN APPROPRIATE WASTE DISPOSAL
FACILITY IN ACCORDANCE W/CURRENT LOCAL, STATE & FEDERAL LAWS &
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CALIBRATING GAS 5% CO2, 95% O2, BALANCE NITROGEN 477442
CAGE:51404
CAGE:51404
============= Composition/Information on Ingredients =============
Ingred Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
= Wt:5.
OSHA PEL:5000 PPM
ACGIH TLV:5000 PPM
Ingred Name:OXYGEN
CAS:7782-44-7
RTECS #:RS2060000
= Wt:95.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS MATERIAL OR ITS VAPORS WHEN
SPILLED IN QUANTITIES ROUTINELY IN USE DOES NOT CAUSE SEVERE OR
IMMEDIATE HEALTH EFFECTS OR REQUIRE IMMEDIATE RECOGNITION TO
PREVENT SUBSEQUENT SERIOUS EFFECTS.
Effects of Overexposure:CARBON DIOXIDE: HEADACHE, SHORTNESS OF BREATH,
NAUSEA, VOMITING, DIZZINESS, CRYOGENIC BURNS, ASPHYXIATION.
OXYGEN: CRYOGENIC BURNS.
Medical Cond Aggravated by Exposure:NONE ESTABLISHED
======================= First Aid Measures =======================
First Aid:EYES: GET MEDICAL ATTENTION IMMEDIATELY. SKIN: SEEK MEDICAL
ADVICE IMMEDIATELY FOR CRYOGENIC BURNS. INHALATION: REMOVE TO
FRESH AIR.INGESTION: NOT A ROUTE OF EXPOSURE.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Extinguishing Media:MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:STANDARD FIRE-FIGHTING PRECAUTIONS SHOULD BE
FOLLOWED WHEN TRYING TO EXTINGUISH ANY FIRE. WEAR FULL BUNKER
GEAR, INCLUDING A POSITIVE PRESSURE SELF-CONTAINED BREATHING
APPARATUS IN ANY ENCLOSED SPACE .
================== Accidental Release Measures ==================
Spill Release Procedures:VAPORS OF SPILLED MATERIAL ARE NON-FLAMMABLE.
ALLOW GAS TO VENTILATE FROM AREA UNTIL NORMAL BREATHING AIR
CONDITIONS ARE MET. RELEASES MUST BE HANDLED BY TRAINED PERSONNEL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CYLINDERS CLOSED WHEN NOT IN USE.
IN ORDER TO MINIMIZE THE RISK OF AN UNCONTROLLED RELEASE OF GAS,
ALWAYS SECURE FULL GAS CYLINDERS AND PROTECT CYLINDERS AND CYLINDER
VALVES FROM DAMAGE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AIR SUPPLYING RESPIRATORY PROTECTION WITH ESCAPE
BOTTLES OR SELF CONTAINED BREATHING APPARATUS MAY BE REQUIRED IF
EXPOSURE TO HAZARDOUS INGREDIENTS MAY EXCEED RECOGNIZED SAFE LIMITS
OR OXYGEN LEVELS A RE DISPLACED TO LEVELS BELOW 19.5%.
Ventilation:HANDLE IN AN AREA WITH GOOD GENERAL ROOM VENTILATION.
Other Protective Equipment:LAB COAT
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Density:N/E
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR GAS;ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG REDUCING AGENTS.
Stability Condition to Avoid:HEATING OR DAMAGING GAS CYLINDERS.
=================== Toxicological Information===================
Toxicological Information:SINCE THE MIXTURE HAS NOT BEEN TESTED AS A
WHOLE, THE TOXICOLOGICAL INFORMATION REPORTED IS FOR THE INDIVIDUAL
CHEMICAL INGREDIENTS. INFORMATION IS REPORTED ONLY FOR THOSE
INGREDIENTS WHICH CAUSE THE PRODUCT TO BE CLASSIFIED AS HAZARDOUS
ACCORDING TO EUROPEAN REGULATIONS. ACCORDING TO APPLICABLE
REGULATIONS, THIS PRODUCT DOES NOT CONTAIN CHEMICAL INGREDIENTS
CLASSIFIED AS HAZARDOUS OR IN SUFFICIE NT CONCENTRATIONS TO
CLASSIFY THE PRODUCT AS HAZARDOUS.
===================== Ecological Information =====================
Ecological:ACCORDING TO APPLICABLE REGULATIONS, THIS PRODUCT DOES NOT
CONTAIN CHEMICAL INGREDIENTS CLASSIFIED AS HAZARDOUS OR IN
SUFFICIENT CONCENTRATIONS TO CLASSIFY THE PRODUCT AS HAZARDOUS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:HAZARDOUS. SHIPPING NAME: COMPRESSED GAS N.O.S.;
HAZARD CLASS: 2 NON-FLAMMABLE GAS; PACKING GROUP: NOT ESTABLISHED;
IDENTIFICATION NUMBER: UN 1956.
===================== Regulatory Information =====================
SARA Title III Information:NOT A HAZARDOUS WASTE
Federal Regulatory Information:TSCA: NOT LISTED
State Regulatory Information:CALIFORNIA PROP 65: NOT LISTED.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:300 QR
CAGE:DO828
CAGE:DO828
CAGE:94058
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTOXYETHANOL
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 9%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
Ingred Name:ETHANOLAMINE
CAS:141-43-5
RTECS #:KJ5775000
Fraction by Wt: 5%
OSHA PEL:3 PPM/6 STEL
ACGIH TLV:3 PPM/6 STEL; 9192
===================== Hazards Identification =====================
Effects of Overexposure:SKIN:IRRITATION. INGESTION: NAUSEA
======================= First Aid Measures =======================
First Aid:SKIN: WASH WITH WATER. INGESTION: CALL PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:WASH WITH WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL REQUIREMENTS.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MANUFACTURER STATES NONE REQUIRED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F; 100C
Vapor Pres:25
Spec Gravity:1.10
Solubility in Water:COMPLETE
Appearance and Odor:BLUE COLOR, CITRUS ODOR
Percent Volatiles by Volume:79
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:MANUFACTURER RECOMMENDS FLUSHING TO SANITARY
SEWER. WASTE DISPOSAL METHOD MUST BE IAW FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:STARTING FLUID CYLINDER
CAGE:53203
CAGE:53203
============= Composition/Information on Ingredients =============
Ingred Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
Other REC Limits:STEL: 30,000 PPM
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM/30000STEL;93
Ingred Name:ETHYL ETHER (SARA III)
CAS:60-29-7
RTECS #:KI5775000
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400PPM/500STEL; 9192
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:N-HEPTANE
CAS:142-82-5
RTECS #:MI7700000
OSHA PEL:500 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9293
Ingred Name:MINERAL OIL, SEVERELY HYDROTREATED, PREDOMINATELY
NAPHTHENIC
CAS:64742-53-6
RTECS #:PY8036000
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS & SYMPTOMS OF OVEREXPOSURE
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:INHAL: DIZZINESS, STRONG ANESTHESIA,
INTOXICATION, UNCONSCIOUNESS. SKIN: IRRITATION UPON PROLONGED
CONTACT, DEFATTING OF SKIN. EYE: IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. ARTIFICIAL RESPIRATION. GET MD
IMMED. SKIN: FLUSH AREA WELL WITH WATER. REMOVE & WASH ANY CLOTHING
SOAKED WITH PRODUCT. EYE: FLUSH WELL WITH RUNNING WATER FOR 15
MINUTES. I NGEST: CALL MD OR POISON CONTROL IMMED.PROPER TREATMENT
IS DEPENDENT ON CONDITION OF PATIENT & AMOUNT INGESTED.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-56 F, (ING 2)
Lower Limits:1.8 (ETHER)
Upper Limits:48.0 (ETHER)
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, WATER FOG OR MIST
ONLY, ALCOHOL FOAM
Fire Fighting Procedures:AVOID POSSIBLE ACCUM OF FLAM VAPORS AT LOW
LVLS, AS VAPOR IS HVR/AIR. NIOSH/MSHA APPROVED SCBA & PROT CLOTHING
SHOULD BE WORN WHEN FIGHTING CHEM FIRES
Unusual Fire/Explosion Hazard:AVOID HAZARDOUS CONTAINER PRESSURES. DO
NOT STORE WHERE TEMPERATURE MAY EXCEED 120 F. DO NOT PUNCTURE OR
INCINERATE CONTAINER.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP AWAY FROM HEAT, FIRE, SPARKS, OR FLAME.
IF CONTENTS ARE RELEASED OR SPILLED, VENTILATE AREA WELL. CO*2 MAY
BE USED AS A PRECAUTIONARY VAPOR BLANKET. SMALL AMOUNTS MAY BE
FLUSHED AWAY WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE WHERE TEMPERATURE MAY
EXCEED 120 F. DO NOT STORE NEAR HEAT, FIRE, FLAME, OR SPARKS.
Other Precautions:READ ALL CAUTIONARY INFORMATION ON CYLINDERS. USE IN
ACCORDANCE WITH DIRECTIONS. DO NOT USE NEAR HEAT, FIRE, FLAME OR
SPARKS. DO NOT SPRAY IN DIRECTION OF BODY. USE ONLY WITH GOOD
VENTILATION. KEEP AW AY FROM CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV IS EXCEEDED WEAR NIOSH/MSHA APPROVED SCBA
OR RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN.
Ventilation:MUST BE ADEQUATE TO MAINTAIN VAPORS AT LESS THAN 400 PPM,
PARTICULARLY AT FLOOR LEVEL (SEE SUPP DATA)
Other Protective Equipment:AS REQUIRED TO AVOID CONTACT W/SKIN, EYES OR
CLOTHING. VAPORS MAY IRRITATE EYES.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
VENTILATION (CON'T): AS VAPORS ARE HEAVIER THAN AIR. AVOID EXCESSIVE
BREATHING OF VAPORS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:94F (ING 2)
Vapor Pres:150 PSIG
Vapor Density:APPROX 2.5
Spec Gravity:0.70
Evaporation Rate & Reference: 7.0 (BUTYL ACETATE = 1)
Solubility in Water:APPROX 7% @ 70 F
Appearance and Odor:PALE YELLOW TO CLEAR LIQ, STRONG ETHEREAL ODOR,
EVAPS QUICKLY, LEAVES LUB RESID
Percent Volatiles by Volume:99
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONTENTS OF CYLS SHOULD NOT BE EXPOSED TO AIR & LIGHT. UNSTABLE
PEROXIDES MAY BE FORMED & CONCENTRATE BY EVAP TO HAZ LVL
Stability Condition to Avoid:HEAT, SPARKS, FLAMES, STRONG OXIDIZERS
Hazardous Decomposition Products:CARBON MONOXIDE MAY FORM ON COMBUSTION
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF CONTENTS PROMPTLY IN SEALED METAL
CONTAINERS, IN ACCORDANCE WITH ALL LOCAL, STATE & FEDERAL
REGULATIONS. AVOID ANY CONTAMINATION OF GROUND WATER. DO NOT
PUNCTURE OR INCINERATE CONTAINER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EZY-BOND
CAGE:0B3F8
CAGE:0B3F8
============= Composition/Information on Ingredients =============
Ingred Name:DIBUTYL PHTHALATE (SARA III)
CAS:84-74-2
RTECS #:TI0875000
Fraction by Wt: 3%
Other REC Limits:5 MG/CUM
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3; 9192
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: IRRITATION. INHALATION:
RESPIRATORY PASSAGES. INGESTION: HARMFUL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN/EYES: IRRITATION. INHALATION: RESPIRATORY
PASSAGES. INGESTION: HARMFUL.
Medical Cond Aggravated by Exposure:SENSITIVE TO COMPONENTS OF THIS
SUBSTANCE MAY SUFFER IRRITATION OF THE SKIN & RESPIRATORY PASSAGES.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LARGE QUANTITIES OF WATER AT LEAST 15 MINS.
SKIN: WASH W/SOAP & PLENTY OF WATER. INHALATION: REMOVE TO FRESH
AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS
DIFFICULT , GIVE OXYGEN. INGESTION: DON'T INDUCE VOMITING. GIVE
LARGE QUANTITIES OF WATER. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE WATER SPRAY, CO2, DRY CHEMICAL, ALCOHOL OR
UNIVERSAL FOAMS.
Fire Fighting Procedures:WHEN WATER EVAPORATED, POLYMER CAN BURN &
PRODUCE CO, CO2 & MAY EVOLVE OTHER TOXIC GASES & VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:MAJOR SPILLS SHOULD BE CONTAINED & COLLECTED
FOR DISPOSAL. MINOR SPILLS MAY BE FLUSED W/WATER TO THE SANITARY
SEWER, IF LOCAL REGULATIONS PERMIT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED TO PREVENT
EVAPORATION.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER CIRCUMSTANCES OF NORMAL USE.
Ventilation:MECHANICAL ROOM VENTILATION IS EXPECTED TO BE SATISFACTORY.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Vapor Pres:17.5
Vapor Density:<1
Spec Gravity:1.08
Evaporation Rate & Reference:(BU AC = 1): 1
Solubility in Water:COMPLETE
Appearance and Odor:WHITE, MILKY FLUID; MILD VINEGAR ODOR.
Percent Volatiles by Volume: 70%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:EVAPORATION
Hazardous Decomposition Products:CO, CO2, & TOXIC GASES/VAPORS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ZEP FS SUPERMARKET SANITIZER, 3249
CAGE:0990Y
CAGE:27674
CAGE:0990Y
============= Composition/Information on Ingredients =============
Ingred Name:QUATERNARY AMMONIUM CHLORIDES;BLEND OF ALKYL DIMETHYLBENZYL
AMMONIUM CHLORIDES;CAS# 68391-01-5 & CAS# 64-17-5 68956-7-6
CAS:68391-01-5
Fraction by Wt: 10-20%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHANOL, ETHYL ALCOHOL; GRAIN-ALCOHOL.
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT IN CONCENTRATED FORM IS A
SEVERE EYE IRRIT. OVEREXPOSURE MAY LEAD TO EYE TISSUE DAM WHICH CAN
BE PERMANENT. SKIN CONTACT MAY PRODUCE IRRIT. EYE IRRITANT. EYE
CONTACT MAY PRODUCE STINGING, BURN ING, INFLAMMATION, & IN EXTREME
CASES MAY PRODUCE CORNEAL DAMAGE. EXPOSURE MAY IRRIT SKIN, & UPPER
RESPIRATORY TRACT*
Effects of Overexposure:*ACCUMULATION OF HARMFUL QUANTITIES OF VAPOR IS
PRECEDED BY SEVERE IRRIT WHICH MAKES OVEREXPOSURE UNLIKELY.
OVEREXPOSURE CAN RESULT IN MILD NARCOTIC EFFECTS, INCLUDING
FLUSHING, HEADACHE, DIZZINESS, & NAUSEA.
Medical Cond Aggravated by Exposure:INGREDIENTS IN PRODUCT MAY
AGGRAVATE EXISTING SKIN, EYE, OR RESPIRATORY DISORDERS.
======================= First Aid Measures =======================
First Aid:IMMED FLUSH CONTAM SKIN W/PLENTY OF WATER FOR @ LEAST 15 MIN.
GET MED ATTEN IF IRRIT DEVELOPS. EYES: IMMED FLUSH EYES W/PLENTY OF
WATER FOR @ LEAST 15 MIN, OCCASIONALLY LIF UPPER & LOWER LIDS. GET
MED ATTEN @ ONCE. INHALE: MOVE EXPOSED PERSON TO FRESH AIR. IF
IRRIT PERSISTS, GET MED ATTEN PROMPTLY. INGEST: DO NOT INDUCE
VOMITING. IF VICTIM IS CONSCIOUS GIVE LOTS OF WATER TO DRINK. GET
MED AT ONCE.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Extinguishing Media:NON COMBUSTIBLE.
Fire Fighting Procedures:WEAR SELF-CONTAINED POSITIVE PRES. BREATHING
APPARATUS.
Unusual Fire/Explosion Hazard:FIRE EXPOSED DRUMS SHOULD BE COOLED WITH
STREAM OF WATER.
================== Accidental Release Measures ==================
Spill Release Procedures:OBSERVE SAFETY PROCEDURE IN SECT 4 & 9 DURING
CLEAN-UP. ABSORB SPILL ON INERT ABSORBENT MATERIAL (EG ZEP-O-ZORB).
PICK UP & PLACE RESIDE IN A SUITABLE WASTE CONTAINER OR IF
PERMITTED, FLUSH TO SEWER.THOROUGHLY RINSE SPILL AREA WITH WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:*DISPOSAL BY FLUSH INTO SANITARY SEWER
W/LOTS OF WTR MAY BE PERMISSIBLE. CONSULT LOCAL, STATE, & FEDERAL
AGENCIES FOR PROPER DISPOSAL METHOD IN AREA.
Other Precautions:STORE TIGHT CLOSED CONTAINR IN DRY AREA @ TEMPS
BETWEEN 40-120F. STORE AWAY FROM STRONG ACIDS & OXIDIZING
COMPOUNDS. KEEP PRODUCT AWAY FROM SKIN/EYES. CLOTHES & SHOES WHICH
ARE CONTAM, SHOULD BE REMOV ED PROMPT & NOT WORN UNTIL CLEANED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL MEASURES ARE REQUIRED
Ventilation:NO SPECIAL MEASURES ARE REQUIRED
Other Protective Equipment:USE OF TIGHT FITTING SAFETY GLASSES
RECOMMENDED IF WEARING CONTACT LENSES.
Work Hygienic Practices:CLOTHING/SHOES WHICH BECOME CONTAMINATED WITH
SUBSTANCE SHOULD BE REMOVED PROMP AND NOT REWORN UNTIL THOROUGHLY
CLEANED.
Supplemental Safety and Health
KEEP OUT OF REACH OF CHILDREN.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:215F,102C
Spec Gravity:1.0
pH:5.5
Evaporation Rate & Reference:1.0 (WATER=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, RED/ORANGE LIQUID WITH A CHARACTERISTIC
"QUAT" ODOR
Percent Volatiles by Volume:90%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
AMMONIA, OXIDES OF NITROGEN, HYDROGEN CHLORIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:LIQUID WASTES ARE NOT PERMITTED IN LANDFILLS.
THIS PRODUCT IS NOT CONSIDERED A HAZ WASTE UN RCRA. UNUSABLE LIQUID
MAY BE ABSORBED ON AN INERT ABSORBENT MATERIAL (EX. ZEP-O-ZORB),
DRUMMED, & TAKEN TO A CHEMICAL OR INDUSTRIAL LANDFILL. IN SOME
AREAS*
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SPRAY 93 GAL, 0047001
CAGE:2N691
CAGE:2N691
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2-BUTOXY-; (2-BUTOXYETHANOL)
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 5-11%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 1-4%
OSHA PEL:400 PPM;500 PPM STEL
ACGIH TLV:400 PPM;500 PPM STEL
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:MAY CAUSE EYE, SKIN/MUC MEMB
IRRIT ON PRLNG CONT. HARMFUL IF SWALLOWED. CONTAINS MATLS WHICH
PENET SKIN & MAY BE ABSORBED IN HARMFUL AMTS IF CONT IS PRLNG &
RPTD. EXCESS INHAL OF VAPS MAY CAUSE RESP IRRIT. CHRONIC:THERE ARE
NO REPORTED CHRONIC EFTS ON THIS CMPDED PROD. RPTD OVEREXP OF
STRAIGHT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:2-BUTOXYETHANOL MAY RSLT IN DMG TO
BLOOD. "ANIMAL STUDIES CLEARLY DEMONSTRATED DOSE-RELATED ADVERSE
EFTS ON CNS, HEMATOPOIETIC TISS, BLOOD, KIDNEYS & LIVER, ASSOC
W/ADMIN OF ETHYLENE GLYCOL M ONOBUTYL ETHER (EGBE). (EXTRACTED FROM
DHHS (NIOSH), PUB NO.90-118). ."
Medical Cond Aggravated by Exposure:ALREADY PRE-EXISTING SKIN
CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYES:IMMED FLUSH W/PLENTY OF WATER FOR AT LST 15 MINS,
HOLDING EYELIDS APART TO ENSURE FLUSHING OF ENTIRE SURF. WASHING
W/IN 1 MIN IS ESSNTL TO ACHIEVE MAX EFTIVENESS. SEEK MED ATTN.
SKIN:WASH W/WATER . IF IRRIT IS EVID, OBTAIN MED ATTN. REMOVE
CONTAM CLTHG. INGEST:RINSE MOUTH W/WATER. GIVE WATER TO DRINK.
OBTAIN MED ATTN IMMED. DO NOT GIVE ANYTHING BY MOUTH TO UNCON PERS.
INHAL:REMOVE PERS(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE TO BOILING
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
================== Accidental Release Measures ==================
Spill Release Procedures:STOP SPILL AT SOURCE. PREVENT RUN OFF. MOP,
SHOVEL, PUMP &/OR ABSORB W/INERT MATERIAL. RINSE REMAINING RESIDUE
W/EXCESS WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT W/EYES OR SKIN. USE
W/ADEQUATE VENTILATION. DO NOT INGEST.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NOT REQUIRED UNDER NORMAL USE.
Ventilation:LOCAL VENTILATION.
Other Protective Equipment:NONE REQUIRED UNDER NORMAL USE.
Work Hygienic Practices:FOLLOW FIRST AID PROCEDURES WHEN NECESSARY.
Supplemental Safety and Health
SPEC GRAV:0.9955 +/- 0.0005 (H*2O=1). VP:APPROX TO WATER. VAP
DENS:APPROX TO WATER. PH:13 +/- 0.2. FIRST AID PROC:TO FRESH AIR.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:SUPP DATA
Vapor Density:SUPP DATA
Spec Gravity:SUPP DATA
pH:SUPDAT
Evaporation Rate & Reference:APPROXIMATE TO WATER
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID, BLUE/TURQUOISE COLOR; FLORAL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ACCORDING TO FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PR-1422 B-1/2,B-1
CAGE:DO563
CAGE:83574
CAGE:DO563
============= Composition/Information on Ingredients =============
Ingred Name:CALCIUM DICHROMATE
CAS:14307-33-6
RTECS #:HX7630000
Fraction by Wt: 5%
OSHA PEL:C, 0.1 MG/M3 (CRO3)
ACGIH TLV:0.05 MG/M3 (CR);8990
Ingred Name:DIMETHYLFORMAMIDE
CAS:68-12-2
RTECS #:LQ2100000
Fraction by Wt: 4%
OSHA PEL:S, 10 PPM
ACGIH TLV:S, 10 PPM; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:POSSIBLE SKIN IRRITATION,
======================= First Aid Measures =======================
First Aid:SKIN:WASH THOROUGHLY WITH SOAP AND WATER.EYE:WASH OUT
IMMEDIATELY WITH LARGE AMOUNT OF WATER;SEE A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:>200F,>93C PMCC
Extinguishing Media:USE ANY EXTINGUISHER APPROVED FOR CL,B FIRES.
Fire Fighting Procedures:N/R(PER MFR).
Unusual Fire/Explosion Hazard:MAY EMIT POTENTIALLY TOXIC VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP EXCESS WITH RAGS OR PAPER TOWELS;CLEAN
AREA WITH MEK.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN CLOSED CONTAINERS IN SHELTERED
AREA.AVOID PROLONGED OR REPEATED SKIN CONTACT.
Other Precautions:N/K.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:N/R(PER MFR)
Ventilation:N/R(PER MFR).
Other Protective Equipment:PROTECTIVE HAND CREAM.
Supplemental Safety and Health
MSDS PREP: 09MAR84. SPEC: CLASS B-4. CALL MFR FOR U/I QTY. KEY 1: N1
================== Physical/Chemical Properties ==================
HCC:D2
Spec Gravity:1.38
Solubility in Water:INSOLUBLE
Appearance and Odor:LIGHT BROWN SYRUP,NO SIGNIFICANT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CAN REACT WITH REDUCING MATERIALS
Hazardous Decomposition Products:OXIDES OF SULFUR,HYDROGEN SULFIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF CURED MATERIAL IN NORMAL TRASH IN
ACCORDANCE WITH LOCAL,STATE,FEDERAL REGULATIONS.DO NOT INCINERATE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NICKEL ANTI-SEIZE LUBRICANT, 51285
Preparer's Name:CATHY GRIFFITH
CAGE:GO402
CAGE:GO402
CAGE:73165
============= Composition/Information on Ingredients =============
Ingred Name:GRAPHITE
CAS:7782-42-5
RTECS #:MD9659600
Fraction by Wt: 10-20%
OSHA PEL:15 MPPCF
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 10-20%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:MINERAL OIL, PETRO DISTIL, ACID-HEATED HEAVY NAPHTHENIC
(SEV SOLV-REFINING &/OR HYDROTREATMENT); (PETROLEUM DISTILLATE)
CAS:64742-18-3
RTECS #:PY8032001
Fraction by Wt: 10-20%
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (SILICON DIOXIDE (QUARTZ))
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 1-5%
OSHA PEL:10 MG/M3 RDUST
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:COMMON LUBRICATING GREASE; (GREASE)
Fraction by Wt: >3%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED
(SEV),HEAVY PARAFFINIC; (HYDROTREATED HEAVY PARAFFINIC DISTILLATE)
CAS:64742-54-7
RTECS #:PY8035501
Fraction by Wt: >3%
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:STEARIC ACID, CALCIUM SALT; (CALCIUM STEARATE)
CAS:1592-23-0
RTECS #:WI3000000
Fraction by Wt: >3%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:THERMAL DECOMPOSITION OR COMBUSTION.
RTECS #:9999999ZZ
Ingred Name:MATLS TO AVOID:OXIDANTS, PERCHLORATES. NICKEL WILL REACT
W/ACIDS TO LIBERATE HYDROGEN GAS WHICH CAN FORM EXPLO (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:MIXTS W/AIR. RXN W/ACIDS CAN LIBERATE HYDROGEN GAS
WHICH CAN FORM EXPLOSIVE MIXTURES W/AIR.
RTECS #:9999999ZZ
Ingred Name:HAZ DECOMP PROD:ATMS TO FORM NICKEL CARBONYL, AN EXTREMELY
TOXIC GAS.
RTECS #:9999999ZZ
Ingred Name:EXPLAN OF CARCIN:ON CARCINS, 1991:ANTIC TO BE CARCIN.
HUMAN:LUNGS, NASAL CAVITIES. SILICA, CRYSTALLINE-QUARTZ: (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:IARC MONOGRAPHS, SUPP, VOL 7, PG 341, 1987:GRP 2A.
NTP 6TH ANNUAL RPT ON CARCINS, 1991:ANTIC TO BE CARCIN.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP:PROD. INHAL OF FREE RESPIRABLE SILICA MAY
CAUSE SILICOSIS/OTHER SERIOUS DELAYED LUNG INJURY. (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:SILICA MAY BE RELS BY GRINDING/MACHINING OF COATED
MATLS. THIS PROD CONTAINS ENCAPSULATED NICKEL PWDR. NO(ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:EXPOS TO FREE RESPIRABLE NICKEL IS ANTIC DURING
NORMAL USE OF THIS PROD.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:& MFR'S RECOMMENDATIONS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE:CONT MAY CAUSE IRRIT. MECH
IRRIT. MAY CAUSE TEARING & REDNESS. SKIN:SLIGHT IRRIT. RPTD/PRLNG
CONT MAY CAUSE SENSIT. INHAL:DUST MAY BE SLIGHTLY IRRIT TO EYES &
RESP TRACTS. PRLNG INHAL MAY BE HARMFUL. INGEST:MAY CAUSE NAUS &
VOMIT. CHRONIC:RPTD & PRLNG INHAL OF GRAPHITE/CARBON DUSTS MAY
CAUSE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NICKEL:IARC MONOGRAPHS ON EVAL OF CARCIN
RISK OF CHEMS TO MAN, VOL 49, PG 257, 1990:GRP 2B. NTP 6TH ANNUAL
RPT (ING 12)
Effects of Overexposure:HLTH HAZ:PULM FIBROSIS, EMPHYSEMA &
PNEUMOCONIOSIS, SEVERITY OF THESE EFTS IS GREATLY INFLUENCED BY
PRESENCE OF OTHER HARMFUL MINERAL DUSTS, MOST NOTABLY CRYSTALLINE
SILICA. THIS PROD CONTAINS ENCAPSU LATED SILICON DIOXIDE (QUARTZ,
SILICA).NO EXPOS TO FREE RESPIRABLE SILICA IS ANTIC DURING NORMAL
USE OF THIS (ING 14)
Medical Cond Aggravated by Exposure:PREEXISTING PULMONARY &
DERMATOLOGICAL DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO HAZARDOUS
COMPONENTS.
======================= First Aid Measures =======================
First Aid:EYE:IMMED FLUSH W/PLENTY OF WATER FOR AT LST 15 MINS. GET MED
ATTN IF IRRIT PERSISTS. SKIN:WASH W/SOAP & WATER. GET MED ATTN IF
IRRIT DEVELOPS/PERSISTS. INHAL:REMOVE TO FRESH AIR. MED PERS MAY
ADMIN O XYGEN IF BRTHG IS DFCLT. SEEK MED ATTN IF SYMPS PERSIST.
INGEST:DO NOT INDUCE VOMIT. GIVE VICTIM GLASS OF WATER/MILK. CALL
MD/POIS CTL CTR IMMED. NEVER GIVE ANYTHING BY MOUTH TO UNCON PERS.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:320F,160C
Extinguishing Media:FOAM, DRY CHEMICAL, WATER FOG, CO*2.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
HALOGENATED EXTING AGENTS (SUCH AS HALON) SHOULD NOT BE USED. TO
CONTROL SPREAD OF FIRE DO NOT USE (SUPDAT)
Unusual Fire/Explosion Hazard:FINELY DIVIDED DUST IN AIR MAY PRESENT
EXPLO HAZ. PVNT DUST BUILDUP. CLSD CNTNRS MAY RUPTURE/EXPLODE (DUE
TO PRESS BUILD-UP) WHEN EXPOS TO EXTREME HEAT.(SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:RECLAIM CLEAN MATERIAL. CONTAMINATED MATERIAL
SHOULD BE SWEPT OR SHOVELED INTO APPROPRIATE WASTE CONTAINER &
DISPOSED OF I/A/W APPLICABLE FEDERAL, STATE & LOCAL REGULATIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PRLNG/RPTD CONT W/SKIN. DO NOT
TAKE INTERNALLY. FOR INDUSTRIAL USE ONLY. STORE AWAY FROM HEAT.
KEEP OUT OF REACH OF CHILDREN. RESP IRRITANT.
Other Precautions:FOLLOW GEN INDUS SAFETY PRECS DURING USE. DO NOT
REUSE EMPTY CNTNRS W/OUT COMMERCIAL CLEAN/RECNDTN. FOLLOW ALL
MSDS/LBL PRECS EVEN AFTER CNTNR IS EMPTIED. HARMFUL IF
INHALED/SWALLOWED. CAUSES SKIN & E YE IRRIT. MAY CAUSE ALLERGIC
SKIN RXN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPRVD DUST/MIST RESP WHEN
GRINDING/MACHINING CURED CMPD, COATING/COATED ITEMS. IF EXPOS
LEVELS ARE UNKNOWN, IF LEVELS EXCEED TLV/PEL/IF EFTS OCCUR, USE
NIOSH/MSHA APPRVD DUST/MIST RESP I/A/W APPLIC HLTH & SFTY REGS
(ING 17)
Ventilation:GENERAL VENTILATION USUALLY ADEQUATE.
Other Protective Equipment:CLEAN CLOTHING TO COVER SKIN. EMERG EYE WASH
AND DELUGE SHOWER WHICH MEETS ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS BEFORE EATING.
Supplemental Safety and Health
FIRE FIGHT PROC:WATER; RING SM FIRES W/DRY SAND, USING NON-SPARKING
SHOVELS; AVOID CREATING DUST CLOUDS, ELIM DRAFTS, LET FIRE EXTING
ITSELF. USE WATER TO COOL EXPOS CNTNRS. WATER STREAM DIRECTED INTO
FIRE MAY CAUSE FROTHING W/SUBSEQUENT SPREAD OF FLAME. EXPLO
HAZ:IRRIT &/OR TOX GASES/FUMES MAY BE GENERATED BY (ING 8)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>550F,>288C
Vapor Density:HVR/AIR
Spec Gravity:1.1767
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRAY PASTE; SLIGHT GREASE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES/OXIDANTS. F2; NH4NO3; HYDRAZINE; NH3; (H2 & DIOXANE);
PERFORMIC ACID; P; SE; S; (TI & KCLO3); (ING 9)
Stability Condition to Avoid:PROLONGED EXPOSURE TO HEAT.
Hazardous Decomposition Products:OXIDES OF CARBON, VARIOUS
HYDROCARBONS. UNDER SPECIAL CNDTNS, NICKEL CAN REACT W/CARBON
MONOXIDE IN REDUCING (ING 11)
==================== Disposal Considerations ====================
Waste Disposal Methods:REVIEW ALL CURRENT FEDERAL, STATE & LOCAL
REGULATIONS REGARDING HEALTH & DISPOSAL FOR APPROPRIATE DISPOSAL
PROCEDURES. INCINERATION PREFERRED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FAST DRY MACHINERY ENAMEL-SAFETY RED, K4363500-00
CAGE:KURFE
CAGE:KURFE
============= Composition/Information on Ingredients =============
Ingred Name:VM & P NAPHTHA
CAS:64742-89-8
Fraction by Wt: 50-99%
OSHA PEL:300 PPM (MFR)
ACGIH TLV:300 PPM (MFR)
Ingred Name:2-NAPHTHALENOL, 1-((4-METHYL-2-NITROPHENYL)AZO)-;
(TOLUIDINE)
CAS:2425-85-6
RTECS #:QK4247000
Fraction by Wt: 8-12%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (AROMATIC
HYDROCARBON)
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 0.5-2%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:N/K
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 0.5-2%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:PIGMENT
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUND/VOS--POUNDS/GALLON: 4.14.
VOLATILE ORGANIC COMPOUND/VOS--GRAMS/LITER: 495.97
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: LIQUID MAY CAUSE EYE BURNS.
PROLONGED SKIN CONTACT WITH LIQUID MAY PRODUCE IRRITATION. EYE,
NOSE AND THROAT IRRITATION MAY RESULT FORM EXPOSURE TO VAPOR.
NARCOTIC EFFECTS OCCUR AT HIGHER CONCEN TRATIONS OF VAPOR.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE CONT: IRRIGATE IMMEDIATELY & THOROUGHLY WITH WATER FOR AT
LEAST 15 MINUTES AND GET MEDICAL ATTENTION. SKIN CONT: FLUSH
IMMEDIATELY AND THOROUGHLY WITH WATER. INHALATION: REMOVE FROM
EXPOSURE, TREA T SYMPTOMATICALLY, AND GET MEDICAL ATTENTION.
INGESTION: CALL A PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:50.0F,10.0C
Lower Limits:0.9%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . AVOID SOLID STREAM OF WATER. USE FOG FOR COOLING.
Unusual Fire/Explosion Hazard:FLAMMABLE VAPORS MAY FORM EXPLOSIVE
MIXTURES WITH AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. FLUSH SPILL
AWAY WITH WATER SPRAY. SMALL SPILLS MAY BE COLLECTED WITH ABSORBENT
MATERIAL. AVOID BREATHING VAPORS AND CONTACT WITH LIQUID.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:MATL IS CLASSIFIED AS FLAMMABLE
LIQUID. KEEP AWAY FROM HEAT, SPKS, & OPEN FLAME. DO NOT STORE
>120F. KEEP CNTNR CLSD & UPRIGHT TO PREVENT LEAKAGE.
Other Precautions:CNTNRS SHOULD BE GROUNDED WHEN POURING. AVOID FREE
FALL OF LIQ IN EXCESS OF FEW INCHES. WORKMEN SHOULD BE REQD TO USE
ONLY NON-FERROUS TOOLS & WEAR NON-SPK SHOES IN AREAS WHERE EXPLO
HAZS EXIST. USE W /VENT ADEQ TO MAINTAIN VAPOR (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH APPROVED RESPIRATOR FOR ORGANIC VAPORS
SHOULD BE WORN IF NEEDED.
Ventilation:LOCAL EXHAUST RECOMMENDED USING SPARK-PROOF FANS.
MECHANICAL GENERAL RECOMMENDED.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:REMOVE AND WASH CONTAMINATED CLOTHING.
Supplemental Safety and Health
OTHER PREC:CONCS BELOW TLV OF 50 PPM. HAZ PROD RESIDUE MAY REMAIN AFTER
PROD HAS BEEN REMOVED FROM ITS CNTNR. DO NOT RE-USE EMPTY CNTNR
W/OUT COMMERCIAL CLEANING/RECONDITIONING. SEE ALSO 29 CODE OF FE D
REG 1910.1000. DO NOT TAKE INTERNALLY. KEEP OUT OF THE REACH OF
CHILDREN.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>232F,>111C
Vapor Pres:19 @ 68F
Vapor Density:HVR/AIR
Spec Gravity:0.90
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NOT KNOWN
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:65.15
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS CAN CAUSE A VIGOROUS REACTION.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:AS WITH ANY OTHER ORGANIC MATERIAL,
COMBUST WILL PRODUCE CARBON DIOXIDE AND PROBABLY CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:MIX WITH A COMPATIBLE CHEMICAL WHICH IS LESS
COMBUSTIBLE AND INCINERATE. OBSERVE ALL FEDERAL, STATE, AND LOCAL
LAWS CONCERNING HEALTH AND POLLUTION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:IPA 411
CAGE:TO564
CAGE:TO564
Contract Num:SP0450-00-M-D730
CAGE:01NQ2
============= Composition/Information on Ingredients =============
Ingred Name:NITRILOTRIACETIC ACID TRISODIUM SALT
CAS:5064-31-3
RTECS #:MB8400000
Ingred Name:SODIUM TRIPOLYPHOSPHATE
CAS:7758-29-4
RTECS #:YK4570000
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYLENEDIAMINETETRAACETIC ACID TETRASODIUM SALT
CAS:64-02-8
RTECS #:AH5075000
Ingred Name:CARBONIC ACID DISODIUM SALT, COMPD. WITH HYDROGEN PEROXIDE
(2:3)
CAS:15630-89-4
Ingred Name:SODIUM CARBONATE
CAS:497-19-8
RTECS #:VZ4050000
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 RAT ESTIMATED 1,600 MG/KG
Reports of Carcinogenicity:NTP:YES IARC:YES
Health Hazards Acute and Chronic:TARGET ORGANS: PRODUCT OR PRODUCT
COMPONENT MAY INCREASE THE RISK OF CANCER BASED ON LIMITED AMINAL
DATA. ACUTE: SKIN: PRIMARY ROUTE OF EXPOSURE, MAY CAUSE SLIGHT
IRRITATION TO THE SKIN. EYE: SEVERE I RRITANT TO THE EYES.
RESPIRATORY: PRIMARY ROUTE OF EXPOSURE; DUSTS CAUSE IRRITATION TO
THE UPPER RESPIRATORY TRACT. INGESTION: MAY CAUSE GASTROINTESTINAL
IRRITATION.
Explanation of Carcinogenicity:NITRILOTRIACETIC ACID, TRISODIUM SALT IS
LISTED AS A POSSIBLE HUMAN CARCINOGEN (IARC-2B; NTP=ANTICIPATED).
Effects of Overexposure:CAUSES IRRITATION OF THE SKIN, EYES AND/OR
RESPIRATORY SYSTEM.
Medical Cond Aggravated by Exposure:NOT KNOWN.
======================= First Aid Measures =======================
First Aid:SKIN: WASH THOROUGHLY WITH SOAP & WATER. REMOVE CONTAMINATED
CLOTHING. GET MEDICAL ATTN IF IRRITATION DEVELOPS OR PERSISTS. EYE:
REMOVE CONTACT LENSES. HOLD EYELIDS APART. IMMEDIATELY FLUSH EYES
WITH PLENTY OF WATER FOR AT LEAST 15 MINS. GET IMMEDIATE MEDICAL
ATTENTION. INHALATION: IF NASAL, THROAT OR LUNG IRRITATION
DEVELOPS-REMOVE TO FRESH AIR & GET MEDICAL ATTENTION. INGESTION: DO
NOT FEED ANYT HING BY MOUTH TO AN UNCONSCIOUS OR CONVULSIVE VICTIM.
DO NOT INDUCE VOMITING. IMMEDIATELY CONTACT PHYSICIAN. DILUTE
CONTENTS OF STOMACH USING 3-4 GLASSES MILK OR WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>93.3C, 200.F
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, FOAM OR WATER
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR POSITIVE PRESSURE
SELF CONTAINED BREATHING APPARATUS (FULL FACE-PIECE TYPE)
Unusual Fire/Explosion Hazard:NO DATA PROVIDED BY RESPONSIBLE PARTY.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. USE SPECIFIED PROTECTIVE
EQUIPMENT. CONTAIN AND ABSORB ON ABSORBENT MATERIAL. PLACE IN WASTE
DISPOSAL CONTAINER. FLUSH AREA WITH WATER. WET AREA MAY BE
SLIPPERY. SPREAD SAND/GRIT
Neutralizing Agent:NO DATA PROVIDED BY RESPONSIBLE PARTY.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLING: NORMAL CHEMICAL HANDLING.
STORAGE: KEEP CONTAINERS CLOSED WHEN NOT IN USE. KEEP DRY. STORE
BELOC 104 DEG F AND AWAY FROM ACIDS AND OXIDIZERS.
Other Precautions:NO DATA PROVIDED BY RESPONSIBLE PARTY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A RESPIRATORY PROTECTION PROGRAM THAT MEETS
OSHA'S 29 CFR 1910.134 AND ANSI Z88.2 REQUIREMENTS MUST BE FOLLOWED
WHENEVER WORKPLACE CONDITIONS WARRANT A RESPIRATOR'S USE. USE AIR
PURIFYING RESPIRATORS WITHIN USE LIMITATIONS ASSOCIATED WITH THE
EQUIPMENT OR ELSE USE SUPPLIED AIR-RESPIRATORS. (SEE SUPPLEMENTAL
BELOW).
Ventilation:ADEQUATE VENTILATION.
NECESSARY.
Other Protective Equipment:USE PROTECTIVE EQUIPMENT IN ACCORDANCE WITH
29CFR 1910 SUBPART 1.
Work Hygienic Practices:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Supplemental Safety and Health
RESPIRATORY PROTECTION CONTINUED: IF AIR-PURIFYING RESPIRATOR USE IS
APPROPRIATE. USE A RESPIRATOR WITH DUST/MIST FILTERS.
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Pres:< 1.0 (MMHG)
Vapor Density:<1.0(AIR=1
Spec Gravity:NOT PROVIDED
pH:(5% SOL)~ 10.7
Evaporation Rate & Reference:<1.00 (ETHER=1)
Solubility in Water:10.0
Appearance and Odor:WHITE TO OFF WHITE, POWDER, SLIGHT ODOR
Percent Volatiles by Volume:NOT PROVIDED
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY REACT WITH STRONG OXIDIZERS
Stability Condition to Avoid:STABLE UNDER NORMAL STORAGE CONDITIONS.
Hazardous Decomposition Products:THERMAL DECOMPOSITION (DESTRUCTIVE
FIRES) YIELDS ELEMENTAL OXIDES.
Conditions to Avoid Polymerization:WILL NOT OCCUR
=================== Toxicological Information===================
Toxicological Information:ORAL LD50 RAT: 1,600 MG/KG; DERMAL LD50
RABBIT: >2,000 MG/KG.
===================== Ecological Information =====================
Ecological:AQUATIC TOXICOLOGY: FATHEAD MINNOW 96 HOUR ACUTE TOXICITY:
220 MG/L; NO EFFECT LEVEL: 130MG/L. DAPHNIA MAGNA 48 HOUR ACUTE
TOXICITY: 170 MG/L; NO EFFECT LEVEL: 22 MG/L. BIODEGRADATION: NO
DATA AVAILAB LE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WATER CONTAMINATED WITH THIS PRODUCT MAY BE SENT
TO A SANITARY SEWER TREATMENT FACILITY IN ACCORDANCE WITH ANY LOCAL
AGREEMENT, A PERMITTED WASTE TREATMENT FACILITY OR DISCHARGED UNDER
A PERMIT. PRODU CT AS IS - INCINERATE OR LAND DISPOSE IN AN
APPROVED LANDFILL.
=================== MSDS Transport Information ===================
Transport Information:NOT APPLICABLE.
===================== Regulatory Information =====================
SARA Title III Information:SARA SECTION 311/312 HAZARD CLASSS:
IMMEDIATE (ACUTE), DELAYED (CHRONIC). SARA SECTION 302 CHEMICALS:
NO REGULATED CONSTITUENT PRESENT AT OSHA THRESHOLDS. SARA SECTION
313 CHEMICALS: NO REGULATED CONS TITUENT PRESENT AT OSHA
THRESHOLDS. SARA REPORTABLE QUANTITY (RQ): NO REGULATED CONSTITUENT
PRESENT AT OSHA THRESHOLDS.
Federal Regulatory Information:TSCA: ALL COMPONENTS OF THIS PRODUCT ARE
LISTED IN THE TSCA INVENTORY. CERCLA REPORTABLE QUANTITY (RQ): NO
REGULATED CONSTITUENT PRESENT AT OSHA THRESHOLDS.
State Regulatory Information:CALIFORNIA SAFE DRINKING WATER AND TOXIC
ENFORCEMENT ACT (PROPOSITION 65) CHEMICALS PESENT: THIS PRODUCT
CONTAINS THESE CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER OR REPRODUCTIVE TOXIC ITY: CAS # 5064-31-3, NITRILOTRIACETIC
ACID, TRISODIUM SALT. MICHIGAN REGULATORY INFORMATION: NO REGULATED
CONSTITUENT PRESENT AT OSHA THRESHOLDS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:4008 ULTRA FLAT LATEX WALL/TRIM PAINT SHELL WHITE
CAGE:EO698
CAGE:01PD6
CAGE:EO698
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
CARCINOGEN, IARC GROUP 3)*98-3*
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 10-20%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:VINYL ACRYLIC RESIN *98-3*
CAS:25067-01-0
Fraction by Wt: 10-20%
Ingred Name:PROPANOIC ACID, 2-METHYL, MONOESTER
W/2,2,4-TRIMETHYL-1,3-PENTANEDIOL, TEXANOL(ESTER ALCOHOL)
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: 1-5%
Ingred Name:NEPHELINE SYENITE *98-3*
CAS:37244-96-5
Fraction by Wt: 5-10%
Ingred Name:GROG; CALCIUM-BARIUM PHOSPHOSILICATE, ALUMINUM SILICATE
FLUX *98-3*
CAS:66402-68-4
Fraction by Wt: 10-20%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 40-50%
Ingred Name:VOLATILE ORGANIC CONTENT: 12 WT/GAL
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY AFFECT INHALATION. SKIN/EYES:
IRRITATION. INGESTION: MAY CAUSE MOUTH & THROAT IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, COUGHING, DIFFICULTY OF BREATHING,
GI DISTURBANCES, HEADACHE, DIZZINESS, DISCOMFORT
Medical Cond Aggravated by Exposure:EYE, SKIN, RESPIRATORY DISORDERS,
ASTHMA LIKE CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED
BREATHING. HAVE TRAINED PERSON GIVE OXYGEN. SKIN: FLUSH W/WATER.
THEN WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH IMMEDIATELY
W/LARGE AMOUN TS OF WATER FOR 15 MINS. OBTAIN MEDICALATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:NONE
Upper Limits:4.2
Extinguishing Media:DRY CHEMICAL/FOAM, WATER FOG, CO2
Fire Fighting Procedures:WATER MAY BE USED TO COOL & PROTECT EXPOSED
CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:IN CLOSED TANKS, WATER/FOAM MAY CAUSE
FROTHING/ERUPTION.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. EVACUATE
ALL PERSONNEL. PLACE COLLECTED MATERIAL IN PROPER CONTAINER. SMALL:
USE ABSORBENT TO PICK UP RESIDUE & DISPOSE OF PROPERLY.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING. KEEP CONTAINERS
TIGHTLY CLOSED & UPRIGHT WHEN NOT IN USE. USE ONLY W/ADEQUATE
VENTILATION. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:DON'T TAKE INTERNALLY. AVOID CONTACT W/SKIN, EYES &
BREATHING OF VAPORS. AVOID CONDITIONS WHICH RESULT IN FORMATION OF
INHALABLE PARTICLES SUCH AS SPRAYING/ABRADING PAINTED SURFACES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE ONLY NIOSH/MSHA APPROVED ELASTOMERIC SEALING
SURFACE FACEPIECE RESPIRATOR OUTFITTED W/ORGANIC VAPOR CARTRIDGES &
PAINT SPRAY DUST/MIST PREFILTERS.
Ventilation:DILUTION/LOCAL EXHAUST TO PREVENT BUILDUP OF VAPORS.
Other Protective Equipment:EYE WASH, SAFETY SHOWER, IMPERVIOUS CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS THOROUGHLY AFTER HANDLING, BEFORE EATING/SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212-477F
Spec Gravity:1.440
Appearance and Odor:SHELL WHITE LIQUID
Percent Volatiles by Volume:62.09
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS/ACIDS
Stability Condition to Avoid:EXTREME HEAT/FIRE, ELEVATED TEMPS, SPARKS,
FLAMES, FREEZING & OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:CO, CO2, OXYGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:AVOID DISCHARGE TO NATURAL WATERS. DISPOSE OF IN
ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CATALYST X-134
CAGE:52519
CAGE:52519
============= Composition/Information on Ingredients =============
Ingred Name:PROPRIETARY COMPONENTS
Fraction by Wt: 100%
ACGIH TLV:SEE SUP DATA
===================== Hazards Identification =====================
Effects of Overexposure:MODERATE SKIN IRRITATION
======================= First Aid Measures =======================
First Aid:WASH SKIN THOROUGHLY WITH WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER
Unusual Fire/Explosion Hazard:COMBUSTIBLE DUST
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP AND REMOVE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN.
Ventilation:LOCAL EXHAUST
Supplemental Safety and Health
PART B OF 2 PART KIT. CONTAINER SIZE: 2 OZ BOTTLE. TLV:LD 50 (ORAL)
14.7 GM/KG,LD 50 (DERMAL 1.0G/KG
================== Physical/Chemical Properties ==================
HCC:D1
Solubility in Water:MODERATE
Appearance and Odor:LIGHT TAN POWDER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY WITH LOCAL,STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CEE-BEE CLEANER R-685
Preparer's Name:H B HANS
CAGE:71361
CAGE:71361
============= Composition/Information on Ingredients =============
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (ALIPHATIC PETROLEUM
SOLVENT)
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 5-10%
ACGIH TLV:1350 MG/M3 (MFR)
Ingred Name:SOLVENT NAPHTHA; (AROMATIC PETROLEUM SOLVENT)
CAS:64742-94-5
RTECS #:WF3100000
Fraction by Wt: 5-10%
ACGIH TLV:1600 MG/M3 (MFR)
Ingred Name:2-BUTOXYETHANOL
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: <5%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:THRU CONT & INH OF VAP. COULD CAUSE
DIZZ. MAY IRRIT EYES & SKIN.ANIMAL STUDIES HAVE CLEARLY
DEMONSTRATED DOSE-RELATED ADVERSE EFFECTS ON THE CNS,THE
HEMATOPOIETIC TISSUES,THE BLOOD,THE KIDNEYS AND THE LIVER,ASSOCD
WITH THE ADMIN OF ETYLENEGLYCOL MONOBUTYL ETHER (EGBE) & ETHYLENE
GLYCOL MONOBUTYL ETHER ACETATE (SUPPL)
Explanation of Carcinogenicity:KEROSENE (PETROLEUM), HYDROTREATED:
GROUP 2A (IARC)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE/SKIN:FLUSH W/WATER FOR AT LEAST 15 MINS. IF ANY
IRRITATION PERSISTS, SEEK MEDICAL ATTENTION. INHAL:REMOVE TO FRESH
AIR. SUPPORT BREATHING (GIVE O2/ARTIFICIAL RESPIRATION) . INGEST:
CALL MD I MMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:200F,93C
Extinguishing Media:CARBON DIOXIDE, WATER FOG OR FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB ON ABSORBENT & PLACE IN SUITABLE
CONTAINER OR FLUSH AREA W/WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT 32-100 F. OPEN BUNGS SLOWLY &
CAREFULLY.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLVS ARE EXCEEDED, MUST BE NIOSH/MSHA
APPROVED.
Ventilation:SUFFICIENT TO KEEP BELOW TLV LIMITS.
Other Protective Equipment:SUFFICIENT TO PREVENT SKIN CONTACT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER. HEALTH HAZARD:(EGBEA).(EXTRACTED FROM
DHHS (NIOSH) PUBLICATION NO. 90-118)
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:26.6F,-3.0C
Spec Gravity:0.986
pH:9-10
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:THICK, TRANSLUCENT BLUE LIQUID; SOLVENT ODOR.
Percent Volatiles by Volume:90
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NOT APPLICABLE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:UNKNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR SEND THROUGH NORMAL WASTE WATER
TREATMENT SYSTEMS. FOLLOW ALL LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HOBART 418
CAGE:28835
CAGE:28835
============= Composition/Information on Ingredients =============
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: 60-100%
OSHA PEL:5 MG/CUM RESPIRABLE
ACGIH TLV:10 MG/CUM
Ingred Name:MANGANESE, MN COMPOUNDS
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 1-5%
OSHA PEL:5 MG/CUM (DUST)
ACGIH TLV:5 MG/CUM (DUST)
Ingred Name:CALCIUM CARBONATE, DOMOLITE, LIMESTONE, WHITING
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 5-10%
OSHA PEL:15 MG/CUM (DUST)
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:SILICATE BINDERS (SODIUM SILICATE) *93-1*
CAS:1344-09-8
Fraction by Wt: 1-5%
ACGIH TLV:10 MG/CUM
Ingred Name:CALCIUM FLUORIDE, FLUORSPAR, CALCIUM DIFLUORIDE, IRTRAN 3,
LIPARITE
CAS:7789-75-5
RTECS #:EW1760000
Fraction by Wt: 5-10%
Other REC Limits:2.5 MG/CUM (AS F)
OSHA PEL:2.5 MG/CUM (AS F)
ACGIH TLV:2.5 MG/CUM (AS F)
Ingred Name:AMORPHOUS FUSED SILICA, SILICON DIOXIDE, QUARTZ, SILICON
INTENTED CHANGE (IC)
CAS:60676-86-0
RTECS #:VV7328000
Fraction by Wt: 1-5%
Other REC Limits:30 MG/CUM TOTAL DUST
OSHA PEL:10 MG/CUM (RESP)
ACGIH TLV:0.1 MG/CUM (RESP) IC
Ingred Name:POTASSIUM SILICATE, POTASSIUM METASILICATE *93-1*
CAS:1312-76-1
Fraction by Wt: 3-7%
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: 0.5-1.5%
OSHA PEL:10 MG/CUM
ACGIH TLV:10 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: SIDEROSIS, PULMONARY
EDEMA, BRONCHITIS. MANGANESE CAN CAUSE METAL FUME FEVER. ARC RAYS
CAN INJURE/BURN SKIN & EYES. LONG TERM EXPOSURE: BRONCHIAL ASTHMA,
LUNG FIBROSIS, SIDEROSIS, MANGANIS M, OSTEOPOROSIS, MOTTLING OF
TEETH, DERMATITIS, PNEUMONIA.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: DISCOMFORT, DIZZINESS, NAUSEA,
DRYNESS, NOSE/THROAT/EYES IRRITATION, NASAL SEPTUM PERFORATION,
MUSCLE WEAKNESS, TREMORS. METAL FUME FEVER: CHILLS, FEVER, UPSET
STOMACH, VOMITING, THROAT IR RITATION, BODY ACHES. SKIN:
IRRITATION,ULCERATION.
======================= First Aid Measures =======================
First Aid:EMPLOY FIRST AID TECHNIQUES RECOMMENDED BY THE AMERICAN RED
CROSS. EYES/SKIN: IF IRRITATION OR FLASH BURNS DEVELOP AFTER
EXPOSURE, CONSULT A PHYSICAN. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Unusual Fire/Explosion Hazard:NON FLAMMABLE. WELDING ARC & SPARKS CAN
IGNITE COMBUSTIBLES.
======================Handling and Storage ======================
Handling and Storage Precautions:ELECTRIC SHOCK CAN KILL. TRAIN THE
WELDER NOT TO TOUCH LIVE ELECTRICAL PARTS, TO INSULATE HIMSELF FROM
WORK/GROUND, & TO KEEP HIS HEAD OUT OF FUMES.
Other Precautions:ONE RECOMMENDED WAY TO DETERMINE THE COMPOSITION &
QUANTITY OF FUMES & GASES TO WHICH WORKERS ARE EXPOSED IS TO TAKE
AN AIR SAMPLE INSIDE THE WELDER'S HELMET IF WORN OR IN THE WORKER'S
BREATHING ZONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED OR EQUIVALENT/AIR SUPPLIED
RESPIRATOR WHEN WELDING IN CONFINED SPACE.
Ventilation:LOCAL EXHAUST AT THE ARC TO KEEP <TLV/PEL.
Other Protective Equipment:ARM PROTECTORS, APRONS, HATS, SHOULDER
PROTECTION AS WELL AS DARK NONSYNTHETIC CLOTHING
Work Hygienic Practices:READ & UNDERSTAND THE MANUFACTURER'S
INSTRUCTIONS & THE PRECAUTIONARY LABEL ON THE PRODUCT.
Supplemental Safety and Health
WELDING FUMES & GASES CANNOT BE CLASSIFIED SIMPLY. THE COMPOSITION &
QUALITY OF BOTH ARE DEPENDENT UPON THE METAL BEING WELDED, PROCESS,
PROCEDURES & ELECTRODES USED. WEAR HAND, HEAD & BODY PROTECTION
WHICH HELP TO PREVENT INJURY FROM RADIATION, SPARKS & ELECTRICAL
SHOCK.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO, CO2, OZONE, NITROGEN OXIDES,
OXIDES OF IRON, MANGANESE, SILICON, TITANIUM, SODIUM, POTASSIUM &
FLUORIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATION SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSABLE CONTAINER OR
LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER, IN FULL COMPLIANCE
W/FEDERAL, STATE & LOC AL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DUAL SHIELD T-4130 LOW ALLOY T-1 FLUX CORED WELDING ELECTROD
Resp. Party Other MSDS Num.:7971-2D
CAGE:84021
CAGE:84021
============= Composition/Information on Ingredients =============
Ingred Name:MANGANESE
CAS:7439-96-5
RTECS #:OO9275000
Minumum % Wt:3.
Maxumum % Wt:4.
OSHA PEL:1 MG/M3 (FUME)
OSHA STEL:3 MG/M3
ACGIH TLV:0.2 MG/M3 (FUME)
ACGIH STEL:C 5 MG/M3
Ingred Name:CHROMIUM
CAS:7440-47-3
RTECS #:GB4200000
< Wt:1.
OSHA PEL:1 MG/M3/C 0.1 MG/M3
ACGIH TLV:0.5 MG/M3/0.05 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:NICKEL
CAS:7440-02-0
RTECS #:QR5950000
Minumum % Wt:1.
Maxumum % Wt:2.
OSHA PEL:0.1 MG/M3(SOLUABLE)
ACGIH TLV:0.1 MG/M3(SOLUABLE)
Ingred Name:SODIUM TITANATE. (MANUFACTURER'S INVALID CAS NUMBER
12034-34-2)
CAS:12034-34-3
OSHA PEL:5 MG/M3 (RESP FRAC)
ACGIH TLV:10 MG/M3 (NUS PART)
Ingred Name:POTASSIUM TITANATE
CAS:12030-97-6
OSHA PEL:5 MG/M3 (RESP FRAC)
ACGIH TLV:10 MG/M3 (NUS PART)
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
OSHA PEL:5 MG/M3 (RESPIRABLE)
ACGIH TLV:10 MG/M3 (DUST)
Ingred Name:SILICA, USE QUARTZ FORMULA. (SIO2)
CAS:14808-60-7
RTECS #:VV7330000
OSHA PEL:0.05 MG/M3 (RESP DST
ACGIH TLV:0.1 MG/M3
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:5 MG/M3 (RESPIRABLE)
ACGIH TLV:10 MG/M3 (DUST)
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
OSHA PEL:5 MG/M3 (SOLUABLE)
ACGIH TLV:5 MG/M3 (SOLUABLE)
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
OSHA PEL:10 MG/M3 (TOT PART)
ACGIH TLV:5 MG/M3 (OX FUME)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE OVEREXP TO GASES, FUMES & DUSTS
MAY INCL IRRIT OF EYES, LUNGS, NOSE & THROAT. SOME TOX GASES ASSOC
W/WELDING MAY CAUSE PULM EDEMA, ASPHY & DEATH. ACUTE OVEREXP MAY
INCL SIGNS & SYMPS SUCH AS WAT ERY EYES, NOSE & THROAT IRRIT, HDCH,
DIZZ, DFCLTY BRTHG, FREQUENT COUGH OR CHEST PAIN. PRESENCE OF
NICKEL CMPDS IN FUME CAN CAUSE METALLIC TASTE, NAUS, TIGHTNESS OF
CHEST, FEVER & ALLERGIC RXN. CHRONI C OVEREXP TO AIR CONTAMINANTS
MAY LEAD TO THEIR ACCUM IN LUNGS, CNDTN WHICH MAY BE SEEN AS DENSE
AREAS ON CHEST X-RAYS. SEVERITY OF CHG IS PROPORTIONAL TO LENGTH OF
EXPOS. CHGS SEEN ARE NOT NECESSARIL Y (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NICKEL: GROUP 2B, IARC MONOGRAPHS VOL
49, P 257, 1990; ANTIC HUMAN CARCIN, NTP 8TH ANNUAL RPT ON CARCINS,
1998. CRYSTALLINE SILICA-QUARTZ: GROUP 1, IARC MONOGRAPHS VOL 68, P
41, 1997; ANTIC HUMAN CARC IN, NTP 8TH ANNUAL RPT ON CARCINS, 1998.
HEXAVALENT CHROMIUM: GROUP 1, IARC MONGRAPHS V 49, P 49, 1989;
KNOWN HUMAN CARCIN, NTP 8TH ANNUAL RPT ON CARCINS, 1998.
Effects of Overexposure:HLTH HAZS: ASSOC W/SYMPS OR SIGNS OF REDUCED
LUNG FUNC/DISEASE. IN ADDN, CHGS ON X-RAYS MAY BE CAUSED BY
NON-WORK FACTORS SUCH AS SMKNG, ETC. NICKEL IS CONSIDERED CARCIN.
LONG TERM OVEREXP TO NICKEL F UMES MAY ALSO CAUSE PULM FIBROSIS &
EDEMA. OVEREXP TO MANGANESE CMPDS MAY AFFECT CNS, W/SYMPS OF
LANGUOR, SLEEPINESS, MUSC WEAK, EMOTIONAL DISTURBS & SPASTIC GAIT.
EXPOS LIMS FOR INGREDS ARE LISTED IN SECTION II. 1989 OSHA TWA FOR
WELDING FUME IS 5 MG/M3. TLV-TWAS SHOULD BE USED AS GUIDE IN CTL OF
HLTH HAZS & NOT AS FINE LINES BETWEEN SAFE & EXCESSIVE CONCS. WHEN
PRODS USED AS RECOM BY ESAB GROUP,& PREVENTIVE MEASURES TAUGHT
(SUPDAT)
Medical Cond Aggravated by Exposure:INDIVIDUALS W/ALLERGIES OR IMPAIRED
RESP FUNC MAY HAVE SYMPS WORSENED BY EXPOS TO WELDING FUMES;
HOWEVER, SUCH REACTION CANNOT BE PREDICTED DUE TO VARIATION IN
COMPOSITION & QTY OF DECOMP PRODS.
======================= First Aid Measures =======================
First Aid:INGESTION: CALL MD IMMEDIATELY . EYES: IMMEDIATELY FLUSH EYES
WITH POTABLE WATER FOR AT LEAST 15 MINUTES. SEEK ASSISTANCE FROM MD
. SKIN: FLUSH WITH COPIOUS AMOUNTS OF WATER. CALL MD (FP N ). IN
CASE OF EMERGENCY, CALL FOR MEDICAL AID. EMPLOY FIRST AID TECHNIQUE
RECOMMENDED BY RED CROSS. INHALATION: IF BREATHING IS DIFFICULT,
GIVE OXYGEN AND CALL FOR MD. FOR ELECTRIC SHOCK, DISCONNECT A ND
TURN OFF THE POWER. IF NOT BREATHING, BEGIN ARTIFICIAL RESPIRATION,
PREFERABLY MOUTH-TO-MOUTH. IF NO DETECTABLE PULSE, BEGIN CPR.
IMMEDIATELY CALL MD. FOR ARC BURN, APPLY COLD, CLEAN COMPRESSES & C
ALL MD.
===================== Fire Fighting Measures =====================
Extinguishing Media:THIS PROD WILL NOT BURN; HOWEVER, WELDING ARCS &
SPKS CAN IGNITE COMBUST & FLAM MATLS. USE EXTING MEDIA RECOM FOR
BURNING MATLS & FIRE SITUATION. SEE ANSI Z49.1 (TOXICOLOGICAL INFO)
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:FLAMMABLE/EXPLOSIVE: NO. ONLY THE
PACKAGING FOR THIS PRODUCT WILL BURN.
================== Accidental Release Measures ==================
Spill Release Procedures:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:READ & UNDERSTAND MFR'S INSTRUCTION &
PREC LABEL ON PROD. SEE ANSI Z-49.1, "SFTY IN WELDING & CUTTING,"
PUB BY AMERICAN WELDING SOCIETY, BOX 351040, MIAMI, FL 33135 & OSHA
PUB 2206 (29 CFR 1910), US G OVT PRINTING OFFICE, SUPERINTENDENT OF
DOCUMENTS, BOX 371954, PITTSBURGH, PA 15250 FOR MORE DETAILS.
Other Precautions:ESAB GROUP REQUESTS USERS OF PRODS STUDY MSDS &
BECOME AWARE OF HAZS & SFTY INFO. TO PROMOTE SAFE USE OF PRODS,
USER SHOULD 1)NOTIFY EMPLOYEES, AGENTS & CONTRACTORS OF INFO ON
MSDS & ANY PROD HAZS & SFTY INFO, 2)FURNISH SAME INFO TO CUSTOMERS
FOR THESE PRODS & 3)REQUEST SUCH CUSTOMERS NOTIFY THEIR (STAB COND
TO AVOID)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRABLE FUME RESPIRATOR OR
AIR SUPPLIED RESPIRATOR WHEN WELDING IN CONFINED SPACE OR WHERE
LOCAL EXHAUST OR VENTILATION DOES NOT KEEP EXPOSURE BELOW TLV.
Ventilation:USE ENOUGH VENT, LOCAL EXHAUST AT ARC OR BOTH, TO KEEP
FUMES & GASES BELOW TLVS IN WORKER'S BRTHG ZONE & GEN AREA. TRAIN
WELDER TO KEEP HIS HEAD OUT OF FUMES.
(TOXICOLOGICAL INFO)
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . WEAR
HEAD, HAND & BODY PROT WHICH HELP TO PVNT INJURY FROM RADIA, SPKS &
(TOXICOLOGICAL INFO)
Work Hygienic Practices:TRAIN THE WELDER NOT TO TOUCH LIVE ELECTRICAL
PARTS AND TO INSULATE HIMSELF FROM WORK AND GROUND.
Supplemental Safety and Health
EFTS OF OVEREXP: IN MSDS ARE FOLLOWED, OVEREXP TO HAZ SUBSTANCES WILL
NOT OCCUR. ELEC ARC WORKING MAY CREATE ONE/MORE OF FOLLOWING HLTH
OR PHYSICAL HAZS. FUMES & GASES CAN BE DANGEROUS TO HLTH. ELEC S
HOCK CAN KILL. ARC RAYS CAN INJURE EYES & BURN SKIN. NOISE (OTHER
INFO)
================== Physical/Chemical Properties ==================
Appearance and Odor:TUBULAR STEEL WIRE CONTAINING MINERALS AND ALLOYS;
ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE CURRENTLY KNOWN.
Stability Condition to Avoid:N/P. OTHER PREC:EMPLOYEES AND
CUSTOMERS, FOR THESE PRODUCTS, OF THE SAME PRODUCT HAZARDS AND
SAFETY INFORMATION.
Hazardous Decomposition Products:WELDING FUMES & GASES CANNOT BE
CLASSIFIED SIMPLY. COMPOSITION & QTY OF BOTH DEPEND ON MATL BEING
WORKED, PROCESS, PROCS & CONSUMABLES USED. OTHER CNDTNS INFLUENCING
COMPOSITION & QTY OF (ECOL INFO)
=================== Toxicological Information===================
Toxicological Information:N/P. EXTING MEDIA:"SFTY IN WELDING & CUTTING"
& SAFE PRACTICES" CODE: SP, PUB BY AWS & NFPA 51B "CUTTING &
WELDING PROCESSES, PUB BY NFPA, BATTERYMARCH PARK, QUINCY, MA 02269
FOR ADDNL FIRE PREVENTION & PROT INFO. EYE PROT: USE FILTER LENS.
AS RULE OF THUMB, START W/SHADE WHICH IS TOO DARK TO SEE WELD ZONE.
THEN GO TO NEXT LIGHTER SHADE WHICH GIVES SUFFICIENT VIEW OF WELD
ZONE. PROVIDE PROT SCREEN S & FLASH GOGGS, IF NEC, TO SHIELD
OTHERS. OTHER PROT EQUIP: & PROT FSHLD & MAY INCL ARM PROTECTORS,
APRONS, HAT, SHOULDER PROTECTION AS WELL AS DARK SUBSTANTIAL CLTHG.
===================== Ecological Information =====================
Ecological:N/P. PHYSICAL DATA: AS SHIPPED, THESE PRODS ARE
NONFLAMMABLE, NON-EXPLOSIVE, NON-REACTIVE & NON-HAZARDOUS. PHYSICAL
STATE: SOLID. HAZ DECOMP PRODS: FUMES & GASES TO WHICH WORKERS MAY
BE EXPOSED INCL: COATINGS ON MATL BEING WORKED (SUCH AS PAINT,
PLATING OR GALVANIZING), NUMBER OF WELDING OPERATIONS & VOL OF WORK
AREA, QUALITY & AMT OF VENT, POSITION OF WORKER'S HEAD W/RESPECT TO
FUME PLUME, AS WEL L AS PRESENCE OF CONTAMINANTS IN ATM (SUCH AS
CHLORINATED HYDROCARB VAPS FROM CLEANING OR PAINTING ACTIVITIES).
WHEN MATLS CONSUMED, FUME & GAS DECOMP PRODS GENERATED ARE
DIFFERENT IN PERCENT & FORM F ROM INGREDS LISTED IN (TRANSPORT
INFO)
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSABLE CONTAINER OR
LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER, IN FULL COMPLIANCE
WITH FEDERAL, STATE AN D LOCAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:N/P. ECOLOGICAL INFO: SECTION II. DECOMP PRODS OF
NORMAL OPERATION INCL THOSE ORIGINATING FROM VOLATILIZATION, RXN OR
OXIDATION OF INGREDS, PLUS THOSE FROM MATL BEING WORKED & COATINGS
ETC, NOTED ABOV E. REASONABLY EXPECTED DECOMP PRODS FROM NORM USE
OF THESE PRODS INCL COMPLEX OF OXIDES & FLUORIDES OF MATLS LISTED,
AS WELL AS CARBON MONOXIDE, CARBON DIOXIDE, OZONE & NITROGEN OXIDES
(REFER TO "CHAR ACTERIZATION OF ARC WELDING FUME" AVAIL FROM AWS).
TLV FOR MANGANESE (0.2 MG/M3) WILL BE REACHED BEFORE GEN LIMIT FOR
WELDING FUMES OF 5 MG/M3 IS REACHED. ONLY WAY TO DETERMINE TRUE
IDENTITY OF DECOMPPRODS IS BY (SARA REG INFO)
===================== Regulatory Information =====================
SARA Title III Information:MANGANESE, CHROMIUM & NICKEL ARE TOX CHEMS
SUBJECT TO REPORTING REQS OF SECTION 313 OF EMER PLANNING &
COMMUNITY RIGHT-TO-KNOW ACT OF 1986 (SARA) & 40 CFR 372. TRANSPORT
INFO: SAMPLING & ANLAYSIS. COM POSITION & QTY OF FUMES & GASES TO
WHICH WORKER MAY BE OVEREXPOSED CAN BE DETERMINED FROM SAMPLE
OBTAINED FROM INSIDE WELDER'S HELMET, IF WORN, OR IN WORKERS BRTHG
ZONE. SEE ANSI/AWS F1.1 "METHOD FOR SAMPLING AIRBORNE PARTICLES
GENERATED BY WELDING & ALLIED PROCESSES," AVAIL FROM AMERICAN
WELDING SOCIETY.
Federal Regulatory Information:N/P. HAZARDOUS INGREDS LISTED IN SECTION
II, COVERS MATLS FROM WHICH PROD IS MANUFACTURED. FUMES & GASES
PRODUCED DURING NORMAL USE OF THESE PRODS ARE COVERED IN REACTIVITY
DATA SECTION. TERM HAZARDOU S SHOULD BE INTERPRETED AS TERM
REQUIRED & DEFINED BY LAWS, STATUTES OR REGS & DOES NOT NECESSARILY
IMPLY THE EXISTENCE OF ANY HAZARD WHEN THE PRODUCTS ARE USED AS
DIRECTED BY THE ESAB GROUP.
State Regulatory Information:WARNING: THIS PRODUCT CONTAINS OR PRODUCES
A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER AND
BIRTH DEFECTS (OR OTHER REPRODUCTIVE HARM) (CALIFORNIA HEALTH &
SAFETY CODE 25249.5 ET SEQ.).
======================= Other Information =======================
| 1 | gloves_mandatory |
=======================================================
Product ID: PROPRIETARY CHEMICAL R, 4H35
Cage: 4W445
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 4W445
Cage: 33110
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHALATION: HARMFUL IF SWALLOWED, INHALED, OR ABSORBED
THROUGH SKIN. MATERIAL IS IRRITATING TO TISSUE OF THE MUCOUS MEMBRANES AND
UNDER RESPIRATORY TRACT. PROLONGED EXPOSURE MAY RESULT IN ALLERGIC REA
CTIONS. EYES: MAY BE SEVERELY IRRITATING TO EYES. SKIN: IRRITATING TO SKIN.
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: CALL A PHYSICIAN. INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING
GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN.
EYES/SKIN: IN CASE OF CONTACT, IMMEDIATELY FLUSH EYES OR SKIN W ITH COPIOUS
AMOUNTS OF WATER FOR AT LEAST 15 MINUTES WHILE REMOVING CONTAMINATED
CLOTHING. INGESTION: WASH OUT MOUTH WITH WATER PROVIDED PERSON IS CONSCIOUS.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: AVOID INHALATION, EYE AND/OR SKIN CONTACT. WEAR NIOSH
APPROVED SUITABLE PROTECTIVE EQUIPMENT. REMOVE ALL SOURCES OF IGNITION.
PREVENT RUN-OFF FROM ENTERING DRAINS, SEWERS AND STREAMS. SPILLS MAY BE CO
LLECTED WITH ABSORBENT MATERIALS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE BY ACCEPTABLE TREATMENT AND/OR INCINERATION.
WASH CONTAMINATED AREA WELL WITH SOAP AND WATER. FOR LARGE SPILLS USE A
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS. FEDERAL, STATE AND LOCAL
REGULATIONS TAKE PRECEDENCE.
Handling And Storage Precautions: MATERIALS IS CLASSIFIED AS AN IRRITANT. KEEP
AWAY FROM EYES AND SKIN. PRODUCT RESIDUE MAY REMAIN ON OR IN "EMPTY PACKAGE.
Other Precautions: ALL PRECAUTIONS FOR HANDLING THE PRODUCT MUST BE USE IN
HANDLING THE "EMPTY" PACKAGE AND RESIDUE. CLEAN BEFORE REUSING OR ALTERING
PACKAGE.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: WATER FOG, CARBON DIOXIDE, DRY CHEMICAL POWDER.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: EMITS TOXIC FUMES UNDER FIRE CONDITIONS. SLIGHT
FIRE HAZARD WHEN EXPOSED TO HEAT OR FLAME.
=======================================================
Control Measures
=======================================================
Respiratory Protection: AN APPROPRIATE NIOSH-APPROVED RESPIRATOR SHOULD BE
WORN, IF NEEDED.
Ventilation: LOCAL EXHAUST: RECOMMENDED. MECHANICAL (GENERAL): REC AT LEAST TEN
AIR CHANGES PER HOUR FOR GOOD GENERAL ROOM VENT.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Physical/Chemical Properties
=======================================================
M.P/F.P Text: >455F,>235C
Vapor Density: 9.2
Spec Gravity: >1.0
Solubility in Water: COMPLETE
Appearance and Odor: OFF-WHITE CRYSTALLINE SOLID. (SOLUBLE IN WATER). ODORLESS
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: CARBON MONOXIDE AND CARBON DIOXIDE. TOXIC
FUMES OF NITRIC OXIDE AND HYDROGEN CHLORIDE GAS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: PROPRIETARY CHEMICAL R, 4H35
Cage: 4W445
Company Name: ABBOTT LABORATORIES DIAGNOSTICS DIVISION
Street: 100 ABBOTT PARK RD
Zipcode: 60064
Label Required IND: Y
Date Of Label Review: 04/23/1998
Status Code: C
Label Date: 04/23/1998
Origination
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: INHALATION: HARMFUL IF SWALLOWED, INHALED, OR
ABSORBED THROUGH SKIN. MATERIAL IS IRRITATING TO TISSUE OF THE MUCOUS
MEMBRANES AND UNDER RESPIRATORY TRACT. PROLONGED EXPOSURE MAY RESULT IN ALLER
GIC REACTIONS. EYES: MAY BE SEVERELY IRRITATING TO EYES. SKIN: IRRITATING TO
SKIN. CHRONIC: INHAL: ALLERGIC REACTIONS.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DIBUTYL SEBACATE
CAGE:DO453
CAGE:MDLSY
CAGE:DO453
============= Composition/Information on Ingredients =============
Ingred Name:SEBACIC ACID, DIBUTYL ESTER; (DIBUTYL SEBACATE)
CAS:109-43-3
RTECS #:VS1150000
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:INGEST:IF VOMIT OCCURS, KEEP HEAD LOWER THAN HIPS TO
HELP PVNT ASPIR. TREAT SYMPTOMATICALLY & (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2:SUPPORTIVELY. GET MEDICAL ATTN IF NEEDED. ANTIDOTE:
NO SPECIFIC ANTIDOTE. TREAT SYMPTOMATICALLY AND SUPPORTIVELY.
RTECS #:9999999ZZ
Ingred Name:RESP PROC:BE BASED ON THE SPECIFIC OPERATION, MUST NOT
EXCEED WORKING LIMITS OF RESP, & MUST BE NIOSH APPRVD. (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:ANY CHEM CARTRIDGE RESP W/ORG VAP CARTRIDGE(S). ANY
GAS MASK W/ORG VAPOR CANISTER (CHIN-STYLE/(ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:BACK-MOUNTED CANISTER). ANY TYPE 'C' SUPPLIED-AIR
RESP OPERATED IN THE PRESSURE-DEMAND/OTHER POSITIVE (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:PRESSURE OR CONTINUOUS-FLOW MODE. ANY SCBA. FOR
FIREFIGHTING & OTHER IMMED DANGEROUS TO LIFE/HEALTH (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:CONDITIONS: ANY SCBA THAT HAS A FULL FACEPIECE & IS
OPERATED IN A PRESS-DEMAND/OTHER POSITIVE-PRESS MODE. (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:ANY SUPPLIED-AIR RESP THAT HAS A FULL FACEPIECE & IS
OPERATED IN A PRESS-DEMAND/OTHER POSITIVE-PRESS (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:MODE IN COMBINATION WITH AN AUXILIARY SCBA OPERATED
IN PRESSURE-DEMAND OR OTHER POSITIVE-PRESSURE MODE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT): 16,000 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION:MAY CAUSE COUGHING
AND IRRITATION OF THE MUCOUS MEMBRANES. SKIN:NO IRRITATION
REPORTED. EYE:MAY CAUSE SLIGHT IRRITATION. INGEST:MAY CAUSE NAUSEA
AND IRRITATION OF THE GASTROINTESTINAL TRACT.
CHRONIC:INHALATION:NO DATA AVAILABLE. SKIN:NO IRRITATION REPORTED.
EYE:NO EFFECTS REPORTED. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:INGESTION:NO DATA AVAILABLE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOS AREA TO FRESH AIR IMMED. PERFORM ARTF
RESP IF NEC. KEEP PERSON WARM & AT REST. TREAT SYMPTOMATICALLY &
SUPPORTIVELY. GET MED ATTN IMMED. SKIN:IT IS UNLIKELY THAT EMER
TREATEMEN T WILL BE REQ. IF ADVERSE EFTS OCCUR, PROCEED
W/FOLLOWING:WASH W/SOAP/MILD DETERGENT & LRG AMTS OF H*2O. GET MED
ATTN. EYE:IF (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:OC
Flash Point:350F,177C
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, WATER SPRAY OR
REGULAR FOAM. FOR LARGER FIRES, USE WATER SPRAY, FOG OR REGULAR
FOAM.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP . MOVE
CNTNR FROM FIRE AREA IF YOU DO IT W/OUT RISK. DO NOT SCATTER
SPILLED MATL W/HIGH-PRESS WATER (SUPDAT)
Unusual Fire/Explosion Hazard:SLIGHT FIRE HAZARD WHEN EXPOSED TO HEAT
OR FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP LEAK IF YOU CAN DO IT WITHOUT RISK. FOR
SMALL SPILLS, TAKE UP WITH SAND OR OTHER ABSORBENT MATERIAL AND
PLACE INTO CLEAN, DRY CONTAINERS FOR LATER DISPOSAL. KEEP
UNNECESSARY PEOPLE AWAY. ISOLATE HAZARD AREA AND DENY ENTRY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:THE FOLLOWING RESPS ARE REC BASED ON INFO FOUND
IN THE PHYSICAL DATA, TOX & HLTH EFTS SECTIONS. THEY ARE RANKED IN
ORDER FROM MIN TO MAX RESP PROT. SPECIFIC RESP SELECTED MUST BE
BASED ON CONTAM LEVEL S FOUND IN THE WORK PLACE, MUST (ING 4)
Ventilation:PROVIDE GENERAL DILUTION VENTILATION.
Other Protective Equipment:ANSI APPRVD EMER EYE WASH & DELUGE SHOWER .
IMPERVIOUS CLOTHING AND EQUIP TO PVNT PROLONGED SKIN CONTACT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC:STREAMS. DIKE FIRE-CONTROL H*2O FOR LATER DISP. USE
AGENTS SUITABLE FOR TYPE OF SURROUNDING FIRE. AVOID BRTHG HAZ VAP,
KEEP UPWIND. FIRST AID PROC:ADVERSE EFTS OCCUR, PROCEED W/FOLLOWI
NG:WASH W/LRG AMTS OF H*2O/NORM SALINE UNTIL NO EVID OF CHEM
REMAINS (AT LEAST 15-20 MIN). GET MED ATTN IMMED. (ING 2)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>367F,>186C
Melt/Freeze Pt:M.P/F.P Text:12F,-11C
Vapor Pres:10 @ 200C
Spec Gravity:0.94
Appearance and Odor:PALE YELLOW LIQUID WITH A SLIGHT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
DIBUTYL SEBECATE: OXIDIZING MATERIALS: MAY REACT.
Stability Condition to Avoid:MAY BURN BUT DOES NOT IGNITE READILY.
AVOID CONTACT WITH STRONG OXIDIZERS, EXCESSIVE HEAT, SPARKS, OR
OPEN FLAME.
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE TOXIC OXIDES OF CARBON.
Conditions to Avoid Polymerization:HAZARDOUS POLYMERIZATION HAS NOT
BEEN REPORTED TO OCCUR UNDER NORMAL TEMPERATURES AND PRESSURES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:93-4040 TETRAKIS(DIETHYLAMINO)ZIRCONIUM,99%
CAGE:3H269
CAGE:3H269
============= Composition/Information on Ingredients =============
Ingred Name:TETRAKIS(DIETHYLAMINO)ZIRCONIUM
CAS:13801-49-5
Fraction by Wt: 100%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MANUFACTURER WAS UNABLE TO PROVIDE ANY
INFORMATION AS OF JANUARY 3, 1996.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, COUGHING, SHORTNESS OF BREATH.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/WATER FOR 15 MINS. SKIN: WASH
AFFECTED AREA W/SOAP & WATER FOR 5 MINS. INHALATION: REMOVE TO
FRESH AIR. INGESTION: GIVE PLENTY OF WATER. OBTAIN MEDICAL
ATTENTION IN ALL CASES .
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, DRY POWDER.
Fire Fighting Procedures:EVACUATE AREA. WEAR A SELF-CONTAINED BREATHING
APPARATUS & FIRE PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:COMBUSTIBLE MATERIAL. MATERIAL MAY BURN
IF INVOLVED IN A FIRE/HEATED TO HIGH TEMPS.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: ABSORB INTO VERMICULITE/OTHER SUITABLE
ABSORBENT. SWEEP UP MATERIAL & DISPOSE OF PROPERLY.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE & STORE MATERIAL UNDER AN INERT
ATMOSPHERE OF NITROGEN/ARGON. KEEP AWAY FROM HEAT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED ORGANIC VAPOR FILTER
MASK.
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:NO OTHER PROTECTIVE EQUIPMENT NEEDED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:233.6F
Appearance and Odor:YELLOW LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, MINERAL ACIDS, HALOGENS, OXIDIZING AGENTS.
Stability Condition to Avoid:MOISTURE SENSITIVE, HEAT.
Hazardous Decomposition Products:CO, CO2, NITROGEN OXIDE, ZIRCONIUM
OXIDE, ORGANIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FERROTITANIUM (HIGH TI GRADE), PC8730
CAGE:1N758
CAGE:1N758
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 9%
OSHA PEL:15 MG/M3 DUST;5 RESP
ACGIH TLV:10 MG/M3 DUST;5 FUME
Ingred Name:CARBON
CAS:7440-44-0
RTECS #:FF5250100
Fraction by Wt: 0-2%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9293
Ingred Name:IRON (PEL AND TVL AS IRON OXIDE)
CAS:7439-89-6
RTECS #:NO4565500
OSHA PEL:10 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: 0-14%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:TITANIUM (LIMITS AS TITANIUM DIOXIDE)
CAS:7440-32-6
RTECS #:XR1700000
Fraction by Wt: 38-75%
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EFFECTS ASSOCIATED WITH OVEREXPOSURE
TO METAL DUSTS MAY INCLUDE RESPIRATORY IRRITATION, CONJUNCTIVITIS,
PNEUMOCONISIS, ETC.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:IF IRRITATION OCCURS,
REMOVE TO FRESH AIR. CONTACT A PHYSICIAN. SKIN:IF IRRITATION
OCCURS, WASH SKIN. CONTACT A PHYSICIAN. EYES:IF IRRITATION OCCURS,
FLUSH EYE S WITH WATER FOR AT LEAST 15 MINUTES. CONTACT A
PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:CLASS D FIRE: DO NOT USE WATER. USE DRY CHEMICAL,
DRY SAND OR CARBON DIOXIDE TO SMOTHER FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. FIRE MAY BE ISOLATED & ALLOWED TO BURN ITSELF OUT. DO NOT DISTURB
BURNING METAL WHILE EXTING FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXPLOSIONS MAY BE INITIATED BY
EXPOSING ANY CONCENTRATED DUST SUSPENSION IN AN ENCLOSED INDUSTRIAL
AREA TO A SPARK OR FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:NO SPECIAL STEPS NECESSARY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID AND CONTROL OPERATIONS WHICH
CREATE DUSTING.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN DUSTY AREAS, USE A NIOSH/MSHA APPROVED
SCHEDULE 21C RESPIRATOR.
Ventilation:LOCAL EXHAUST IS RECOMMENDED WHERE DUSTING MAY OCCUR. USE
MECHANICAL (GENERAL) VENTILATION FOR GENERAL AREA CONTROL.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:2912F,1600C
Spec Gravity:5
Solubility in Water:INSOLUBLE/NEGLIGIBLE
Appearance and Odor:GRAYISH METALLIC, LUMP OR POWDER, ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, STRONG OXIDIZERS, STRONG BASES AND MOISTURE.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:OZZYJUICE SW-1 ACTIVATING DEGREASING SOLUTION
Preparer's Name:T MCNALLY
CAGE:GO681
CAGE:GO681
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MILD IRRITANT. SKIN: NO
HAZARDOUS EFFECTS EXPECTED. IF SWALLOWED, AS A RESULT OF INDUSTRIAL
HANDLING IS NOT LIKELY TO CAUSE INJURY. INHALATION: NO KNOWN
EFFECTS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES/SKIN: RINSE W/LARGE AMOUNTS OF WATER UNTIL NO EVIDENCE
OF CHEMICAL REMAINS. INGESTION: TREAT SYMPTOMATICALLY. INHALATION:
REMOVE TO FRESH AIR & OBSERVE. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:OC
Flash Point:NONE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:DILUTE PRODUCT W/WATER & FLUSH INTO A SANITARY
SEWER.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT FROM FREEZING. KEEP CONTAINER
CLOSED WHEN NOT IN USE. FOLLOW LABEL INSTRUCTIONS. KEEP THIS & ALL
CHEMICALS OUT OF REACH OF CHILDREN.
BE WORN WHEN HANDLING ANY INDUSTRIAL USE PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED.
Ventilation:NOT REQUIRED
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:210F
Spec Gravity:1.083
pH:7
Solubility in Water:COMPLETE
Appearance and Odor:FREE FLOWING HONEY COLORED W/SLIGHT PLEASANT SWEET
ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:FREEZING
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:GLID-GUARD ALKYD TANK & STRUCTURAL ENAMEL,5
CAGE:72818
CAGE:72818
============= Composition/Information on Ingredients =============
Ingred Name:MAGNESIUM SILICATE,HYDRATE (TALC).CONTAINING NO ASBESTOS
FIBERS.OSHA PEL IS FOR DUST W/ <1% CRYSTALLINE SILICA.
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 4-9%
Other REC Limits:N/K
OSHA PEL:2 MG/M3 RESP DUST
ACGIH TLV:2 MG/M3 RESP DUST
Ingred Name:TITANIUM DIOXIDE (RUTILE).ACGIH TLV IS FOR DUST WITH NO
ASBESTOS AND <1% CRYSTALLINE SILICA.OSHA PEL:5 MG/M3 RESP DUST.
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 27-32%
Other REC Limits:N/K
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:ETHYLBENZENE.LOWER EXPLOSIVE LIMIT:1.0 %.VAPOR PRESSURE:7.1
MMHG.
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 1-5%
Other REC Limits:N/K
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ALKYD RESIN
CAS:67700-92-9
Fraction by Wt: 30-35%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DISTILLATES (PETROLEUM) HYDRO-TREATED,LIGHT (MINERAL
SPIRITS).LOWER EXPLOSIVE LIMIT:0.7%.VAPOR PRESSURE:3.0 MMHG.
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 18-23%
Other REC Limits:100 PPM (MFR)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC (MINERAL
SPIRITS).LOWER EXPLOSIVE LIMIT:1.0%.VAPOR PRESSURE:2.5 MMHG.
CAS:64742-88-7
Fraction by Wt: 7-12%
Other REC Limits:100 PPM (MFR)
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED OR REPEATED CONTACT CAN
CAUSE DERMATITIS, CORNEAL INJURY. SOLVENT OVEREXPOSURE RELATED TO
PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE. EXCESSIVE SOLVENT
INHALATION CAN CAUSE ASPHYXIATION & DEATH . CONCENTRATING &
INHALING VAPORS CAN BE HARMFUL/FATAL. CAN CAUSE BLOOD
ABNORMALITIES, LIVER & KIDNEY DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:PRLNG/RPTD CONT CAN CAUSE SEVERE
IRRIT,BLURRED VISION,TEARING,REDNESS.SKIN:IRRIT,PRLNG/RPTD CONT CAN
CAUSE DEFATTING.INGEST:LARGE AMTS MAY CAUSE LUNG INFLAMMATION & DMG
DUE TO ASPIRATION.INHAL:IR RIT OF RESP TRACT.PROLONGED INH MAY
CAUSE MUCOUS MEMBRANE
IRRIT,FATIGUE,DROWSINESS,DIZZINESS/LIGHTHEADEDNESS,(SEE SUPP)
Medical Cond Aggravated by Exposure:NOT EXPECTED TO AGGRAVATE ANY
CONDITION,HOWEVER INGREDIENTS HAVE BEEN REPORTED TO AGGRAVATE
PREEXISTING EYE,SKIN,RESPIRATORY DISORDERS,LUNG DISORDERS,AND
ASTHMA-LIKE CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH IMMED W/ LARGE AMOUNTS OF WATER,ESP UNDER LIDS,FOR
AT LEAST 15 MIN.OBTAIN EMERGENCY MEDICAL TREATMENT.SKIN:WASH OFF
QUICKLY W/ PLENTY OF WATER,THEN SOAP & WATER;REMOVE CONTAM
CLOTHING.INGES T:OBTAIN MEDICAL TREATMENT IMMED.INHAL:REMOVE TO
FRESH AIR.RESTORE & SUPPORT CONTINUED BREATHING.GET EMER MED
ATTN.HAVE TRAINED PERSON GIVE OXYGEN IF NEC.GET MEDICAL HELP FOR
ANY BREATHING DIFFICULTY.
===================== Fire Fighting Measures =====================
Flash Point:100F,37.78C
Lower Limits:0.7
Extinguishing Media:DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SELF-CONTAINED
BREATHING APPARATUS AND FULL PROTECTIVE EQUIPMENT .WATER MAY BE
USED TO COOL AND PROTECT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLSD CNTNRS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT/FIRE.VAPS CAN FORM EXPLOSIVE MIXS IN AIR AT HIGH
TEMPS.MAY DECOMPOSE IN FIRE EMITTING IRRITANT (SEE SUPP)
================== Accidental Release Measures ==================
Spill Release Procedures:COMPLY WITH ALL APPLICABLE HEALTH AND
ENVIRONMENTAL REGULATIONS.ELIMINATE ALL SOURCES OF
IGNITION.VENTILATE AREA.SPILLS MAY BE COLLECTED WITH
NON-COMBUSTIBLE ABSORBENT MATERIALS.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:STORE <100F,37.78C.KEEP AWAY FROM
HEAT,SPKS,OPEN FLAME.USE ONLY W/ ADEQ VENT.AVOID CONT W/
SKIN,EYES,& BRTHG OF VAPS.KEEP CNTNR UPRIGHT,TIGHTLY CLSD.
Other Precautions:DO NOT TAKE INTERNALLY.KEEP OUT OF REACH OF
CHILDREN.IF SANDING IS DONE,WEAR A DUST MASK TO AVOID BREATHING
SANDING DUST.EMPTY CONTAINERS MAY CONTAIN HAZ RESIDUES.GROUND
EQUIPMENT WHEN TRANSFERRING TO PREVENT ACCUMULATION OF STATIC
CHARGE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW
APPLICABLE STANDARDS.WHERE RESPIRATORY PROTECTION IS REQUIRED,USE
ONLY NIOSH/MSHA APPROVED RESPIRATORS IN ACCORDANCE WITH OSHA
STANDARD 29 CFR 1910.134.
Ventilation:PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT
BUILDUP OF VAPORS.
Other Protective Equipment:EYE WASH,SAFETY SHOWER
Work Hygienic Practices:WASH HANDS THROUGHLY AFTER HANDLING,ESPECIALLY
BEFORE EATING OR SMOKING.WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
BOILING POINT:273-374F,133.89-190C. EXPLO HAZ: AND/OR TOXIC GASES. HAZ
DECOMP PROD:CO & CO*2. EFTS OF OVEREXP: HEADACHE, INCOORDINATION,
NAUSEA, VOMITING, CENTRAL NERVOUS SYSTEM DEPRESSION, ANESTHETIC
EFFECT OR NARCOSIS.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:SEE SUPP
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/K
Vapor Density:N/K
Spec Gravity:1.23,WATER=1
Evaporation Rate & Reference:N/K
Solubility in Water:N/K
Appearance and Odor:N/K
Percent Volatiles by Volume:49.7
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS,ACIDS,BASES,AMINES.
Stability Condition to Avoid:ELEVATED TEMPERATURES
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .AVOID DISCHARGE TO NATURAL
WATERS.ETHYLBENZENE:SARA TITLE III SECTION 313 LISTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:STANNOUS (TIN) CHLORIDE, #7030
CAGE:0W741
CAGE:56894
CAGE:0W741
============= Composition/Information on Ingredients =============
Ingred Name:STANNOUS CHLORIDE
CAS:7772-99-8
RTECS #:XP8700000
Fraction by Wt: 100%
OSHA PEL:2 MG/M3 (SN)
ACGIH TLV:2 MG/M3 (SN); 8990
===================== Hazards Identification =====================
Effects of Overexposure:MAY BURN EYES/IRRITATE SKIN AND MUCOUS
MEMBRANES. SLIGHTLY TOXIC BY INGESTION.
======================= First Aid Measures =======================
First Aid:EYE CONTACT: FLUSH W/WATER FOR 15 MIN. GET MED ATTN. SKIN
CONTACT: WASH W/SOAP & WATER. IF IRRITATED GET MED ATTN.
INHALATION: REMOVE TO FRESH AIR. IF IRRITATED, GET MED ATTN.
INGESTION: DRINK WATER. DON'T INDUCE VOMITING. CALL PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:MATERIAL DOESN'T BURN OR SUPPORT COMBUSTION.
Fire Fighting Procedures:APPROPRIATE PROTECTIVE APPAREL.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SALVAGE AS MUCH MATERIAL AS POSSIBLE. SWEEP UP
REMAINING MATERIAL AND TRANSFER TO WAE TREATMENT OR CONTAINERIZE.
======================Handling and Storage ======================
Handling and Storage Precautions:WARNING. MAY CAUSE BURNS ON EYES. MAY
BE IRRITAINT TO SKIN AND MUCOUS MEMBRANES. KEEP CONTAINECLOSED WHEN
NOT IN USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED BREATHING MASK WHERE DUSTY
CONDITION EXIST.
Ventilation:ACCEPTABLE
Supplemental Safety and Health
MSDS DATE: 9/25/86. MELTING POINT: 246C
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:652C
Spec Gravity:3.95
Solubility in Water:45%
Appearance and Odor:WHITE OR SOLID WITH NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:EXTREME HEAT
Hazardous Decomposition Products:HYDROCHLORIC ACID IF HEATED IN THE
PRESENCE OF ACIDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:NEUTRALIZE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LIONITE ALUMINUM OXIDE, GF
CAGE:84330
CAGE:84330
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM OXIDE; (ALPHA-ALUMINA)
CAS:1344-28-1
RTECS #:BD1200000
Fraction by Wt: 96.4%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 2.7%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:SILICA GEL; (SILICON DIOXIDE)
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 0.5%
OSHA PEL:6 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:MAGNESIUM OXIDE
CAS:1309-48-4
RTECS #:OM3850000
Fraction by Wt: 0.2%
OSHA PEL:15 MG/M3 PARTICULATE
ACGIH TLV:10 MG/M3;TDUST; 9293
Ingred Name:IRON (III) OXIDE
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 0.1%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
Ingred Name:CALCIUM OXIDE
CAS:1305-78-8
RTECS #:EW3100000
Fraction by Wt: 0.1%
OSHA PEL:5 MG/M3
ACGIH TLV:2 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPOSURE TO EXCESSIVE AIRBORNE
CONCENTRATIONS MAY RESULT IN ACUTE RESPIRATORY DISORDERS.
INDIVIDUALS W/IMPAIRED PULMONARY FUNCTION SHOULD NOT BE SUBJECTED
TO EXCESSIVE AIRBORNE CONCENTRATIONS. SYMPTOM S OF EXCESSIVE
EXPOSURE MIGHT INCLUDE DEPOSITS OF MATERIAL IN EYES, EARS, NASAL
PASSAGES & IRRITATION (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:OF MUCOUS MEMBRANES, EYES &
RESPIRATORY TRACT. IRRITATION OF SKIN MAY ALSO OCCUR DUE TO
MECHANICAL/CHEMICAL ACTION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOSURE. SEE MD. EYE:IRRIGATE W/COPIOUS
QUANTITIES OF WATER FOR AT LEAST 15 MINUTES. SEE MD. SKIN:IRRIGATE
W/COPIOUS QUANTITIES OF WATER. SEE MD. INGEST:CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
================== Accidental Release Measures ==================
Spill Release Procedures:NORMAL PRECAUTIONS FOR INERT OR NUISANCE DUSTS
& PARTICULATES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE HANDLING PROCEDURES WHICH WILL
LIMIT EXPOSURE TO EXCESSIVE AIRBORNE DUST.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:UTILIZE NIOSH/MSHA APPROVED RESPIRATORY
PROTECTION DEVICES FOR NUISANCE DUST.
Ventilation:UTILIZE LOCAL EXHAUST TO KEEP AIRBORNE CONCENTRATION BELOW
TLV.
Other Protective Equipment:ARM SLEEVES OR BARRIER CREAMS MAY BE USEFUL
IN PREVENTION OF DERMATITIS.
Work Hygienic Practices:MAINTAIN NORMAL HOUSEKEEPING PROCEDURES FOR
NUISANCE DUST.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:3722F,2050C
Vapor Pres:0
Spec Gravity:3.95
Solubility in Water:INSOLUBLE
Appearance and Odor:LIGHT TO DARK BROWN; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE W/HOT CHLORINATED RUBBER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN COMPLIANCE W/ALL FEDERAL, STATE &
LOCAL LAWS & REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:56397 57217 ANTI-D SLIDE/TUBE
CAGE:67018
CAGE:67018
CAGE:67823
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Ingred Name:SODIUM AZIDE, AZIDE *98-1*
CAS:26628-22-8
RTECS #:VY8050000
Fraction by Wt: 0.1%
Other REC Limits:0.1 PPM
ACGIH TLV:C 0.29 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 27 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF SWALLOWED, INHALED/ABSORBED
THROUGH SKIN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:HEADACHE, NAUSEA, BLURRED VISION, DIZZINESS,
LOW BLOOD PRESSURE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH THOROUGHLY W/WATER FOR 15 MINS. SKIN: RINSE
W/PLENTY OF WATER FOR 15 MINS. INHALATION: REMOVE TO FRESH AIR. AID
IN BREATHING IF NECESSARY. INGESTION: FLUSH MOUTH. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:DRY CHEMICAL/CO2
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: WEAR PROTECTIVE CLOTHING TO GUARD
AGAINST EYE & SKIN CONTACT. USE SPILL PILLOWS/OTHER APPROPRIATE
ABSORBENT. PLACE MATERIALS IN SEALED CONTAINER FOR PROPER DISPOSAL.
LARGE: WEAR SELF CONTAINEDBREATHING APPARATUS & FULL PROTECTIVE
CLOTHING.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BETWEEN 35.6-46.4F. DON'T STORE
NEAR ACIDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER NORMAL PRODUCT USE.
Ventilation:USE W/ADEQUATE VENTILATION.
Other Protective Equipment:CHEMICAL RESISTANT APRON, PROTECTIVE
CLOTHING
Work Hygienic Practices:GOOD HYGIENE PRACTICES SHOULD BE FOLLOWED TO
AVOID EYE & SKIN CONTACT W/THIS PRODUCT.
Supplemental Safety and Health
THESE PRODUCTS CONTAIN MATERIALS THAT HAVE BEEN PREPARED FROM HUMAN
BLOOD COMPONENTS & SHOULD BE HANDLED AS IF CAPABLE OF TRANSMITTING
INFECTIOUS AGENTS. THESE PRODUCTS CONTAIN 0.1% SODIUM AZIDE AS A
PRESERVATIVE. THEREFORE, WE HAVE ENCLOSED A MSDS FOR 0.1 SODIUM
AZIDE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Vapor Pres:AS WATER
Evaporation Rate & Reference:(WATER=1): 1
Appearance and Odor:COLORLESS LIQUID W/NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS
Hazardous Decomposition Products:TOXIC HYDRAZOIC GAS, MAY FORM
EXPLOSIVE LEAD/COPPER AZIDE IN LABORATORY PLUMBING
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS. MAY FORM EXPLOSIVE LEAD/COPPER AZIDE IN
LABORATORY PLUMBING.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1802 ULTRA-FLAT BACK DECORATOR PAINTS
Resp. Party Other MSDS Num.:DEC/KRH2
CAGE:EO392
CAGE:EO392
CAGE:0RKV4
============= Composition/Information on Ingredients =============
Ingred Name:PROPANE (PROPELLANT)
CAS:74-98-6
RTECS #:TX2275000
= Wt:15.
OSHA PEL:1800 MG/M3
Ingred Name:ETHYLBENZENE
CAS:100-41-4
RTECS #:DA0700000
= Wt:2.
OSHA PEL:100 PPM
OSHA STEL:125 PPM
ACGIH TLV:100 PPM
ACGIH STEL:125 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE
CAS:1330-20-7
RTECS #:ZE2100000
= Wt:31.
OSHA PEL:100 PPM
OSHA STEL:150 PPM
ACGIH TLV:100 PPM
ACGIH STEL:150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE
CAS:67-64-1
RTECS #:AL3150000
= Wt:34.
OSHA PEL:750 PPM
OSHA STEL:1000 PPM
ACGIH TLV:750 PPM
ACGIH STEL:1000 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:BUTYL BENZYL PHTHALATE
CAS:85-68-7
RTECS #:TH9990000
= Wt:1.
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:AMORPHOUS SILICA
CAS:7631-86-9
= Wt:1.
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
= Wt:2.
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRITATION OF EYES, SKIN AND
RESPIRATORY SYSTEM. MAY CAUSE NERVOUS SYSTEM DEPRESSION. EXTREME
OVEREXPOSURE MAY RSULT IN UNCONSCIOUSNESS AND POSSIBLY DEATH.
CHRONIC-PROLONGED OVEREXPOSURE TO SO LVENT INGREDIANTS MAY CAUSE
ADVERSE EFFECTS TO THE LIVER, URINARY, BLOOD-FORMING,
CARDIO-VASCULAR AND REPRODUCTIVE SYSTEMS.METHYL ETHYL KETONE MAY
INCREASE THE NERVOUS SYSTEM EFFECTS OF OTHER SOLVEN TS. REPORTS
HAVE ASSOCIATED REPEATED AND PROLONGED OVEREXPOSURE TO SOLVENTS
WITH PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:NO INGREDIENT IN THIS PRODUCT IS AN
IARC, NTP OR OSHA LISTED CARCINOGEN.
Effects of Overexposure:HEADACHE, DIZZINESS,NAUSEA, AND LOSS OF
COORDINATION ARE INDICATIONS OF EXCESSIVE EXPOSURE TO VAPORS OR
SPRAY MISTS.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:IIF INHALED: REMOVE FROM EXPOSURE, RESTORE BREATHING. KEEP
WARM AND QUIET. IF ON SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP
& WATER. REMOVE CONTAMINATED CLOTHING & LAUNDER BEFORE RE-USE. IF
IN EYES : FLUSH EYES WITH LARGE AMOUNTS OF WATER FOR 15 MINUTES.
GET MEDICATL ATTENTION. IF SWALLOWED: GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:<-17.6C, 0.F
Lower Limits:0.9
Upper Limits:13.3
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT INCLUDING
SELF-COTNAINED BREATHING APPARATUS SHOULD BE USED. WATER SPRAY MAY
BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE PREFERABLE WATER
MAY BE USED TO COOL CLOS ED CONTAINERS TO PREVENT PRESSURE
BUILD-UP AND POSSIBLE AUTOIGNITION OR EXPLOSION WHEN EXPOSED TO
EXTREME HEAT.
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT,
SPARKS & OPEN FLAME. CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT. APPLICATION TO HOT SURFACES MAY CREATE A HEALTH
HAZARD. DURING EMERGENCY CONDI TIONS OVEREXPOSURE TO DECOMPOSITION
MAY CREATE A HEALTH HAZARD. SYMPTOMS MAY NOT BE IMMEDIATELY
APPARENT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM SOURCES OF IGNITION.
VAPORS WILL ACCUMULATE READILY & MAY IGNITE EXPLOSIVELY. KEEP AREA
VENTILATED. CONSULT NFPA CODE. USE PROPER BONDING & GROUNDING.
CONTENTS UNDER PRESSURE. DO NOT PU NCTURE, INCINERATE OR EXPOSE TO
TEMPERATURES ABOVE 120F. DO NOT TAKE INTERNALLY.
Other Precautions:INTENTIONAL USE BY DELIBERATELY CONCENTRATING &
INHALING THE CONTENTS CAN BE HARMFUL OR FATAL. DURING USE KEEP AWAY
FROM FLAMES, PILOT LIGHTS, HEATERS. TURN OFF STOVES, ELECTRICAL
TOOLS AND APPLIANCES .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONEL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, WEAR A PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESPIRATOR APPROVED BY NIOSH/MSHA FOR PROTECTION
AGAINST INGREDIENTS. WHEN SANDING OR ABRADING THE DRIED FILM, WEAR
A DUST/MIST RESPIRATOR APPROVED BY NIOSH/MSHA FOR DUST WHICH MAY BE
GENERATED FROM THIS PRODUCT.
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF
EXPOSURE TO INGREDIENTS IS MAINTAINED BELOW APPLICABLE EXPOSURE
LIMITS.
APPLICATION OF AEROSOL PRODUCTS WHERE MINIMAL SKIN CONTACT IS
EXPECTED.
Work Hygienic Practices:USE ONLY WITH ADEQUATE VENTILATION. AVOID
BREATHING VAPORS AND SPRAY MIST. AVOID CONTACT WITH SKIN AND EYES.
WASH HANDS AFTER USE. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
NFPA CODE 30B LEVEL: 3. HMIS RATING (HEALTH-FLAMMABILITY-REACTIVITY):
2-4-0.
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:<0-302F
Vapor Density:>AIR
Volatile Org Content %:85
Evaporation Rate & Reference:FASTER THAN ETHER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NONE KNOWN
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
OXIDES OF METALS IN INGREDIENTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THIS PRODUCT MAY BE HAZARDOUS AS
DEFINED BY RCRA (40 CFR 261). WASTE MUST BE TESTED FOR IGNITABILITY
TO DETERMINE APPLICABLE EPA HAZARDOUS WASTE NUMBERS. WASTES
CONTAINING METHYL ETHYL KETO NE OR MAY REQUIRE TESTING FOR
EXTRACTABILITY. DO NOT INCINERATE. DEPRESSURIZE CONTAINER. DISPOSE
OFIAW FEDERAL, STATE & LOCAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:DOT CLASSIFICATION: ORM-D CONSUMER COMMODITY.
===================== Regulatory Information =====================
SARA Title III Information:ETHYLBENZE, XYLENE, ACETONE: INGREDIENTS
SUBJECT TO THE REPORTING REQUIREMENTS OF THE SUPERFUND AMENDMENTS
AND REAUTHORIZATION ACT (SARA) SECTION 313, 49 CFR 372.65C.
State Regulatory Information:PURSUANT TO PROPOSITION 65: THESE PRODUCTS
CONTAIN TOLUENE WHICH IS KNOWN BY THE STATE OF CALIFORNIA TO CAUSE
REPRODUCTIVE TOXICITY.
| 1 | gloves_mandatory |
=======================================================
Product ID: GCO-30, 02295
Cage: DUBOI
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 72008
Cage: DUBOI
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE & CHRONIC:DEFATS SKIN; MAY IRRITATE EYES.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: SENSITIVE SKIN.
First Aid: INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP)
(FP N). EYES:FLUSH THOROUGHLY W/FRESH WATER FOR AT LEAST 15 MINUTES. GET
MEDICAL ATTENTION. SKIN:FLUSH W/FRESH WATER, WASH W/SOAP & WA TER. REMOVE
CONTAMINATED CLOTHING & SHOES. INGEST:GIVE MILK OR WATER. INDUCE
VOMITING. GET MEDICAL ATTENTION. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: FLUSH SMALL AMOUNTS TO DRAIN. COLLECT & RETURN
LARGE AMOUNTS TO CONTAINER. PREVENT SPILLS FROM ENTERING OPEN BODIES OF
WATER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISP MUST BE I/A/W FED, STATE & LOC REGS (FP N). PH
ADJUSTMENT; CONTAINS NO PHOSPHATES. WARNING:PVNT COOLING SYS OVERFLOW FROM
ENTERING STORM WATER DRAINS. USE UNTIL <1 INCH REMAINS IN CNTNR. EMPTY CN
TNR:TRIPLE RINSE CNTNR W/WATER, ADD TO (SUPP DATA)
Handling And Storage Precautions: DO NOT PRESSURE CONTAINER TO EMPTY. KEEP
CONTAINER CLOSED. IF FROZEN, THAW & MIX TO MAKE USABLE.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONE
Lower Limits: NONE
Upper Limits: NONE
Extinguishing Media: CO*2, FOAM, DRY CHEMICALS.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N). NONE.
Ventilation: MECHANICAL:NORMAL AIR DILUTION.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: WASTE DISP METH:OPERATION. REMOVE OR DEFACE
LABEL BEFORE SELLING CONTAINER OR DISPOSAL.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 215F,102C
Vapor Pres: 17.5 @ 20C
Spec Gravity: 1.13
Evaporation Rate & Reference: >1 (N-BUTYL ACETATE=1)
Solubility in Water: 100%
Appearance and Odor: CLEAR LIQUID; MILD ODOR.
Percent Volatiles by Volume: 90
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: INCOMPATIBLE W/CONCENTRATED MINERAL ACIDS.
Hazardous Decomposition Products: CO W/INCOMPLETE COMBUSTION.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: GCO-30, 02295
Cage: DUBOI
Assigned IND: Y
Company Name: DUBOIS CHEMICALS DIV OF CHEMED CORP
Street: 3630 E KEMPER ROAD
Zipcode: 45241
Label Required IND: Y
Date Of Label Review: 03/26/1996
Status Code: C
Label Date: 03/26/1996
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE & CHRONIC:DEFATS SKIN; MAY IRRITATE EYES.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ECCOFLOAT EF-38B, PART B
Kit Part:Y
CAGE:HO526
CAGE:HO526
CAGE:04552
============= Composition/Information on Ingredients =============
Ingred Name:LIQUID POLYAMIDE RESIN
Fraction by Wt: 100%
Ingred Name:SUPP DATA: EMULSIFY. WASH AREA WITH SOAPY WATER AND RINSE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: VAPORS MAY IRRITATE EYES,
NOSE AND THROAT. EYE: SEVERE IRRITATION UPON DIRECT CONTACT. SKIN:
IRRITATION UPON DIRECT CONTACT. PROLONGED EXPOSURE MAY RESULT IN
SKIN SENSITIZATION. INGESTION: HARMFUL IF SWALLOWED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYE: IMMEDIATELY FLUSH EYES
WITH WATER FOR AT LEAST 15 MINUTES; GET MEDICAL ATTENTION. SKIN:
REMOVE CONTAMINATED CLOTHING. RINSE AFFECTED AREA WITH 5% ACETIC
ACID. WAS H WITH SOAP AND WATER. INGESTION: DILUTE WITH LARGE
QUANTITIES OF WATER; INDUCE VOMITING ONLY IF VICTIM IS CONSCIOUS
AND ALERT. GET IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>365F,>185C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:TOXIC FUMES MAY BE EVOLVED UPON EXPOSURE
TO HEAT OR OPEN FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILL: WIPE UP/ABSORB
W/VERMICULITE/OTHER ABSORB MATL. IF ACETONE/OTHER SIMILAR SOLV ARE
USED,BE SURE TO USE ADEQ VENT & FIRE SAFETY PREC.COLLECT WASTE IN
SEALED CNTNRS. SCRUB AREA W/5% ACETIC A CID TO EMULSIFY. WASH AREA
W/SOAPY H*2O(SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE; KEEP REMOVED
FROM HEAT OR OPEN FLAME. KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:KEEP AWAY FROM INTENSE HEAT, OPEN FLAMES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:FLEXIBLE DUCTWORK SHD EXTEND TO AREAS OF HIGH CONC TO PVNT
LOCAL BUILD-UP OF VAP.PROVIDE SPECIAL VENT AT ELEVATED TEMPS.
Other Protective Equipment:PROTECTIVE CLOTHING.
Work Hygienic Practices:AVOID SKIN AND EYE CONTACT. AVOID BREATHING
FUMES OR VAPORS. USE ONLY WITH ADEQUATE VENTILATION.
Supplemental Safety and Health
SPILL PROC: & RINSE. LRG SPILLS: TURN ON ALL VENT EQUIP IN AREA TO
EVACUATE FUMES. DIKE AREA TO PVNT SPREADING. SHOVEL/PUMP SPILLED
MATL TO DRUM/SALVAGE TANK. ABSORB RESIDUAL MATL W/SAND,
VERMICULITE/ OTHER ABSORB MATL. SCRAPE/SHOVEL ABSORBWASTE & ABSORB
INTO SEALED CNTNRS. SCRUB AREA W/5% ACETIC ACID TO (ING 2)
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Pres:<1
Vapor Density:HVR/AIR
Spec Gravity:0.97
Appearance and Odor:LIGHT YELLOW TO AMBER LIQUID; SLIGHT AMINE ODOR.
Percent Volatiles by Volume:NEG
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS, PEROXIDES.
Stability Condition to Avoid:HEAT AND/OR OPEN FLAMES, EXPOSURE TO
INCOMPATIBLE SUBSTANCES, STORAGE IN OPEN CONTAINERS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN, AMMONIA.
==================== Disposal Considerations ====================
Waste Disposal Methods:SPILLED MATERIAL & WATER RINSES ARE CLASSIFIED
AS CHEMICAL WASTE AND THEY MUST BE DISPOSED OF EITHER BY BURIAL IN
CHEMICAL LANDFILL OR BY CONTROLLED BURNING AT LICENSED CHEMICAL
WASTE FACILITY IN ACCO RDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CREATININE REAGENT #214441
CAGE:24143
CAGE:24143
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 0.2%M
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PICRIC ACID (SARA III)
CAS:88-89-1
RTECS #:TJ7877000
Fraction by Wt: 30% M M
OSHA PEL:S, 0.1 MG/M3
ACGIH TLV:0.1 MG/M3; 9192
===================== Hazards Identification =====================
Routes of Entry: Inhalation:UNKNOWN Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:CONTACT MAY CAUSE BURNS TO SKIN
AND EYES.NO OTHER DATA AVAILABLE.
Explanation of Carcinogenicity:DATA PER MGF MSDS.
Effects of Overexposure:SEE HEALTH HAZARDS DATA.
Medical Cond Aggravated by Exposure:PRE-EXISTING CONDITIONS MAY BE
WORSEN.
======================= First Aid Measures =======================
First Aid:EYES AND SKIN:FLUSH WITH LARGE AMOUNT OF WATER FOR ABOUT
15-20 MINUTES,SEEK MEDICAL ATTENTION IMMEDIATELY.INHALATION:REMOVE
TO FRESH AIR,CALL A PHYSICIAN.INGESTION:SEEK MEDICAL ATTENTION
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NOT FLAMMABLE;USE CARBON DIOXIDE, FOAM, DRY
CHEMICAL, OR WATER FOG IF APPLICABLE.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:NONE SPECIFIED
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;REAGENT A:FLUSH
AREA WITH LARGE AMOUNT OF WATER .IN CASE REAGENT B:USE INERT
ABSORBENT MATERIAL AND COLLECT FOR PROPER DISPOSAL.
Neutralizing Agent:LARGE AMOUNT OF WATER
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE AS DIRECTED,WEAR PROTECTIVE
CLOTHING TO AVOID EYES AND SKIN CONTACT.
Other Precautions:WASH THOROUGHLY AFTER EACH USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMALLY NOT NEEDED IF USED AT ROOM VENTILATION.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV.
Other Protective Equipment:PROTECTIVE CLOTHINGS.EYE-WASH FACILITIES,
Work Hygienic Practices:AVOID CONTACT WITH EYES AND SKIN;DO NOT BREATHE
VAPORS/MIST.WASH THOROUGHLY AFTER EACH USE.
Supplemental Safety and Health
HANDLING REAGENT A AND WORKING SOLUTION SINCE THEY WILL STAIN SKIN
AND CLOTHING.
================== Physical/Chemical Properties ==================
HCC:B1
Solubility in Water:AQUEOUS SOLUTION
Appearance and Odor:REAGENT A:CLEAR YELLOW SOLUTION;REAGENT
B:CLEAR,COLORLESS SOLUTION.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:NOT SPECIFIED
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES;DISPOSAL MUST BE IN
ACCORDANCE WITH LOCAL,STATE AND FEDERAL REGULATIONS
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AUPHAUSER 681/656/773/189/510/520/#1 FLUX
CAGE:59401
CAGE:59401
============= Composition/Information on Ingredients =============
Ingred Name:ZINC (SARA III)
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: 0-45%
Other REC Limits:NONE ESTABLISHED
OSHA PEL:10 MG ZNO/M3
ACGIH TLV:10 MG ZNO/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: 0-1.5%
Other REC Limits:NONE ESTABLISHED
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 0-1.0%
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 0-13%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: 0-3.5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
Fraction by Wt: 0-3%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9192
Ingred Name:SILVER (SARA III)
CAS:7440-22-4
RTECS #:VW3500000
Fraction by Wt: 0-0.7%
OSHA PEL:0.01 MG/M3
ACGIH TLV:0.1 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:BORIC ACID
CAS:10043-35-3
RTECS #:ED4550000
Fraction by Wt: 0-7%
Other REC Limits:NONE ESTABLISHED
Ingred Name:COPPER (SARA III)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: BAL.
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2MG/M3 FUME; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SHORT TERM EXPOSURE TO WELDING FUME
MAY RESULT IN DISCOMFORT, DIZZINESS, NAUSEA, OR DRYNESS OR
IRRITATION OF THE THROAT. LONG TERM EXOOSURE TO WELDING FUMR, GASES
OR DUST MAY CONTRIBUTE TO PULMONARY I RRITATION OR PNEUMOCONIOSIS.
Explanation of Carcinogenicity:NICKEL IS LISTED BY IARC & NTP AS
CARCINOGNIC.
Effects of Overexposure:METALLIC TASTE,NAUSEA TIGHTNESS OF
CHEST,FEVER,DIZZINESS.EYE,NOSE,THROAT DRYNESS AND IRRITATION.
======================= First Aid Measures =======================
First Aid:REMOVE FROM EXPOSURE AND OBTAIN PROMPT MEDICAL ATTENTION.IF
UNCONSCIOUS,GIVE OXYGEN.IF NOT BREATHING GIVE CPR.EMPLOY FIRST AID
TECNIQUES RECOMMENDED BY AMERICAN RED CROSS.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:EXTINGUISH WITH AGENT SUITABLE FOR SURROUNDING FIRE
Unusual Fire/Explosion Hazard:WELDING ARC AND SPARKS CAN IGNITE
COMBUSTIBLE PRODUCTS
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP ANY GRINDING DUST OR WASTE RESIDUE
AND PLACE IN SUITABLE DOT APPROVED DISPOSAL CONTAINER.
======================Handling and Storage ======================
Other Precautions:TRAIN WELDER TO KEEP HIS HEAD OUT OF THE
FUMES,MONITOR AIR TO ENSURE ACCEPTABLE EXPOSURES.AVOID ELECTRICAL
SHOCK BY MAINTAINING DRY WORK AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FUME RESP.OR AIR SUPPLIED RESP.IN CONFINED
SPACES.
Ventilation:LOCAL EXHAUST TO MAINTN BELOW TLV.
Other Protective Equipment:SUBST.DK.CLOTH,ARM
PROTECTOR,APRON,HAT,SHOULDR.PROTECTION.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:WELDING ROD 0.187 IN DIA.BY 36 IN LONG
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:FUMES OF METALS AND METAL
OXIDES,CO,NO*2,O*3.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL,STATE AND
FEDERAL REGULATIONS
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:Y 1608 WOODMASTER STAIN
CAGE:DO304
CAGE:72818
CAGE:DO304
============= Composition/Information on Ingredients =============
Ingred Name:VM&P NAPHTHA (LIGROINE)
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 69%
Other REC Limits:STEL 400 PPM
OSHA PEL:300 PPM/400 STEL
ACGIH TLV:300 PPM; 9192
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 1%
Other REC Limits:NUISANCE PARTICULATE
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: FATIGUE, DIZZINESS,
HEADACHE, CNS DEPRESSION. IRRITATION OF EYES, SKIN, RESP TRACT.
SKIN: DERMATITIS, DEFATTING. EYE: BLURRED VISION, TEARING/REDNESS.
INGESTION: NAUSEA, VOMITING, DIARRHEA , DIGESTIVE SYSTEM PROBLEMS,
ANESTHETICEFFECT, NARCOSIS, SEVERE LUNG IRRITATION/DAMAGE, &
UNCONSCIOUSNESS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING & INHALING THE CONTENTS MAY BE HARMFUL OR FATAL.
SKIN: PROLONGED/REPEATED CONTACT MAY CAUSE DERMATITIS. EYE: BLURRED
VISION, TEARING/REDNESS. OVEREXPOS URE TO SOLVENTS CAUSES PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE.
Medical Cond Aggravated by Exposure:DERMATITIS
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE/SUPPORT BREATHING.
SKIN: WASH OFF QUICKLY W/PLENTY OF SOAP & WATER. REMOVE/WASH
CONTAMINATED CLOTHING BEFORE RE-USE. EYES: FLUSH W/LARGE AMOUNTS OF
WATER FOR A T LEAST 15 MINS. OBTAIN EMERGENCY MEDICAL TREATMENT.
INGESTION: OBTAIN MEDICAL TREATMENT IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:102F
Lower Limits:0.7%
Extinguishing Media:DRY CHEMICAL OR FOAM
Fire Fighting Procedures:WATER MAY BE USED TO COOL & PROTECT EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT/FLAME. VAPORS CAN FORM EXPLOSIVE MIXTURES
IN AIR AT ELEVATED TEMPERATURES.
================== Accidental Release Measures ==================
Spill Release Procedures:COMPLY W/ALL APPLICABLE HEALTH & ENVIRONMENTAL
REGS. VENTILATE AREA. SPILLS MAY BE COLLECTED W/ABSORBENT
MATERIALS. LARGE SPILLS: SHUT OFF LEAK IF SAFE TO DO SO.
DIKE/CONTAIN SPILL. PUMP TO STORAGE/SA LVAGE VESSELS. USE ABSORBENT
TO PICK UPRESIDUE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE <100F. KEEP AWAY FROM HEAT,
SPARKS, & OPEN FLAME. USE ONLY W/ADEQUATE VENTILATION. DON'T TAKE
INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:AVOID CONTACT W/SKIN, EYES, & BREATHING OF VAPORS.
WASH HANDS THOROUGHLY AFTER HANDLING, ESPECIALLY BEFORE EATING OR
SMOKING. KEEP CONTAINERS TIGHTLY CLOSED & UPRIGHT WHEN NOT IN USE.
EMPTY CONTAINERS MAY CONTAIN HAZARDOUS RESIDUES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF >TLV IS REQUIRED, US NIOSH/MSHA APPROVED
RESPIRATORS. IF SANDING IS DONE, WEAR A DUSTMASK TO AVOID BREATHING
OF SANDING DUST.
Ventilation:PROVIDE LOCAL EXHAUST/MECHANICAL VENTILATION TO KEEP <TLV
Other Protective Equipment:SAFETY SHOWER, EYE WASH.
Work Hygienic Practices:REMOVE/WASH CONTAMINATED CLOTHING BEFORE
RE-USE.
Supplemental Safety and Health
WT PER GAL: 7.34 LBS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:308-374F
Percent Volatiles by Volume:77.87%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, BASES, AMINES
Stability Condition to Avoid:ELEVATED TEMPERATURES, HEAT, SPARKS, &
OPEN FLAME.
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FP-1307, PANASONIC DEVELOPER FQ-Z120-P (SUP
CAGE:S0293
CAGE:S0293
============= Composition/Information on Ingredients =============
Ingred Name:IRON (III) OXIDE; (FERRITE) (ALT MFR CAS NOS:1317-38-0,
1314-13-2, 1309-48-4)
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 80%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
Ingred Name:TONER; (FQ-T50K-P)
Fraction by Wt: 20%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HEALTH HAZARD IS MINIMAL BEING NEITHER
IRRITATING, CORROSIVE, VOLATILE NOR TOXIC. MUTAGENICITY IS
NEGATIVE. CONTACT W/EYES MAY RESULT IN MECHANICAL IRRITATION.
INHALATION OF DUST MAY IRRITATE MUCOUS M EMBRANES. INGESTION MAY
RESULT IN GASTRIC DISTURBANCES. TLV OF PROD REC BY MFR:8 MG/M3
TDUST;2 RESP.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:IMMED WASH W/RUNNING WATER FOR AT LST 15 MINUTES. IF
IRRIT DEVELOPS, GET MD. SKIN:WASH AFFECTED AREAS W/SOAP & WATER. IF
IRRIT DEVELOPS, GET MD. REMOVE & LAUNDER CONTAM CLTHG BEFORE REUSE.
INGEST :IF SWALLOWED DILUTE W/WATER & IMMED INDUCE VOMIT. GET MD IF
VICTIM IS UNCONSCIOUS OR HAVING CONVULSIONS. INHAL:REMOVE TO FRESH
AIR AREA. AID IN BRTHG IF NECESSARY & GET MD.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, CO*2, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . NOT FLAMMABLE OR COMBUSTIBLE BUT WILL BURN
IF IGNITED.
Unusual Fire/Explosion Hazard:NONE UNDER NORMAL STORAGE AND USE
CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM OR SWEEP UP DRY POWDER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID DUST INHALATION AND SKIN
CONTACT.
Other Precautions:KEEP CONTAINERS CLOSED. STORE IN A COOL, DRY PLACE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL USE. USE NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE REQUIRED UNDER NORMAL USE.
Other Protective Equipment:NONE REQUIRED UNDER NORMAL USE.
Work Hygienic Practices:MINIMIZE BREATHING DUST.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:MAGNEFINE DEVELOPER.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:4.2 (H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:FINE BLACK POWDER, PRACTICALLY ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:ABNORMALLY HIGH TEMPERATURE.
Hazardous Decomposition Products:NONE IN NORMAL HANDLING AND USE.
Conditions to Avoid Polymerization:ABNORMALLY HIGH TEMPERATURE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W LOCAL, STATE & FEDERAL
REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:LIQUID EPOXY COATING SURE-POXY HI-BILD (SUPP DATA)
Kit Part:Y
CAGE:KAUFM
CAGE:KAUFM
============= Composition/Information on Ingredients =============
Ingred Name:POLYOXYPROPYLENE AMINE; (BLEND OF COMPLEX ALIPHATIC ETHER
AMINES)
CAS:9046-10-0
Ingred Name:PIPERAZINE,1-(2-AMINOETHYL)-; (A-AMINO PIPERAZINE)
CAS:140-31-8
RTECS #:TK8050000
Ingred Name:PHENOL; (PHENOLS), MFR CAS. NO 2514-42-3.
CAS:108-95-2
RTECS #:SJ3325000
OSHA PEL:5 PPM, S
ACGIH TLV:5 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE, IF PIGMENTED)
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CLAY (KAOLIN); (HYDROUS KAOLIN, IF PIGMENTED)
CAS:1332-58-7
RTECS #:GF1670500
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF SKIN & ESPECIALLY EYES.
COULD CAUSE A RASH, BURN OR AN ASTHMATIC TYPE RESPONSE IN
SENSITIZED PERSONS. POSSIBLE PERMANENT EYE INJURY.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST: DO NOT INDUCE VOMITING. GIVE LARGE AMOUNTS OF WATER
AND AT LEAST 1 OUNCE OF VINERGAR IN EQUAL AMOUNTS OF WATER. CALL
MD. INHAL: SUPPLY FRESH AIR. EYES: FLUSH WITH COPIOUS AMOUNTS OF
WATER FOR AT LEAST 15 MINUTES. CALL MD. SKIN: REMOVE CONTAMD
CLOTHING. WASH WITH SOAP & WATER FOR AT LEAST 15 MINUTES.
===================== Fire Fighting Measures =====================
Flash Point:255F,124C
Extinguishing Media:FOAM, DRY CHEMICAL, WATER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:AVOID CONTACT WITH LIQUID AND BREATHING
SMOKE.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP LEAK. CLEAN WITH CLOTH OR ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL PLACE AWAY FROM SPARKS
AND FLAME.
Other Precautions:KEEP OUR OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED ORGANIC RESPIRATOR.
Ventilation:LOCAL EXHAUST RECOMMENDED.
Other Protective Equipment:APRON & BOOTS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
TRADENAME/PART #: ORANGE COMP B, 743.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:500F,260C
Spec Gravity:1.02-1.38
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:PARTIAL
Appearance and Odor:AMONICAL ODOR. CLEAR OR PIGMENTED LIQUID.
Percent Volatiles by Volume:1 MAX
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS ACIDS AND BASES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, ALDEHYDES AND OTHER
ORGANICS.
==================== Disposal Considerations ====================
Waste Disposal Methods:GOVERNMENT APPROVED CHEMICAL DISPOSAL OR
LANDFILL. DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CERAMIGOLD 2
CAGE:12164
CAGE:12164
============= Composition/Information on Ingredients =============
Ingred Name:DUST, NUISANCE
Other REC Limits:NONE RECOMMENDED
Ingred Name:METAL OXIDE
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICA - QUARTZ
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICA - CRISTOBALLTE
Other REC Limits:NONE RECOMMENDED
Ingred Name:GRAPHITE (TYPE NOT SPECIFIED)
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:WHIP MIX RECOMMENDES 0.05 MG/M3 (DUST)
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION OF EXCESSIVE DUST OVER A
PROLONGED PERIOD CAN RESULT IN LUNG DAMAGE, SILICOSIS.
Explanation of Carcinogenicity:IARC REPORTS THAT THERE IS LIMITED
EVIDENCE FOR THE CARCINOGENICITY OF CRYSTALLINE SILICA TO HUMANS.
Effects of Overexposure:EYE & SKIN IRRITATION-MAY CAUSE DRYNESS AND/OR
IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:FLUSH EYES WITH WATER FOR 15 MINUTES. WASH SKIN.
===================== Fire Fighting Measures =====================
Flash Point:NO FIRE HAZARD.
Extinguishing Media:THIS MATERIAL POSES NO FIRE OR EXPOLSION HAZARD.
Fire Fighting Procedures:THIS MATERIAL POSES NO FIRE OR EXPLOSION
HAZARD.
Unusual Fire/Explosion Hazard:THIS MATERIAL POSES NO FIRE OR EXPLOSION
HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM; AVOID CREATING DUST. AVOID WASHING
DOWN DRAINS AS MATERIAL PLUGS DRAINS.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:MINIMIZE DUST GENERATION AT ALL TIMES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE APPROPIATE NIOSH-APPROVED RESPIRATOR TO
AVOID EXPOSURE ABOVE THE RECOMMENDED LIMITS.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:3
Solubility in Water:ONLT SLIGHTLY
Appearance and Odor:ODORLESS POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HYDROFLUORIC ACID.
Stability Condition to Avoid:BASICALLY STABLE, MAY SOLIDIFY IF
CONTACTED BY WATER.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:NO SPECIAL TREATMENT REQUIRED.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:D-5460NS MOLY DRY LUBE (AEROSOL), PRODUCT CODE:63 2000
Preparer's Name:J. SMITH
CAGE:UO257
CAGE:UO257
Contract Num:SP0450-01-M-C961
CAGE:1KQX9
============= Composition/Information on Ingredients =============
Ingred Name:MOLYBDENUM DISULFIDE
CAS:1317-33-5
RTECS #:QA4697000
< Wt:5.
Ingred Name:ISOPROPYL ALCOHOL
CAS:67-63-0
RTECS #:NT8050000
= Wt:5.
OSHA PEL:980 MG/M3;400 PPM
ACGIH TLV:983 MG/M3;400 PPM
ACGIH STEL:1230 MG/M3;500 PPM
Ingred Name:PROPYLENE GLYCOL N-BUTYL ETHER
CAS:5131-66-8
RTECS #:UA7700000
< Wt:5.
Ingred Name:ETHANOL
CAS:64-17-5
RTECS #:KQ6300000
= Wt:10.
OSHA PEL:1900 MG/M3;1000 PPM
ACGIH TLV:1880 MG/M3;1000 PPM
Ingred Name:1,1-DIFLUOROETHANE
CAS:75-37-6
RTECS #:KI1410000
Minumum % Wt:25.
Maxumum % Wt:30.
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: BREATHING HIGH CONCENTRATIONS
OF VAPORS MAY CAUSE TEMPORARY NERVOUS SYSTEM DEPRESSION AND
ANESTHETIC EFFECTS SUCH AS DIZZINESS, HEADACHE, NAUSEA. CHRONIC:
PROLONGED EXPOSURE TO EXTREMELY HIGH C ONCENTRATIONS OF VAPORS MAY
LEAD TO NARCOSIS, CARDIAC IRREGULARITIES, UNCONSCIOUSNESS OR DEATH.
Explanation of Carcinogenicity:NO
Effects of Overexposure:INHALTION(ACUTE):NAUSEA, DIZZINESS, AND/OR
HEART IRREGULARITIES MAY OCCUR FROM BREATHING HIGH CONCENTRATIONS.
CHRONIC: BREATHING EXTREMELY HIGH CONCENTRATIONS OF VAPORS MAY LEAD
TO ANESTHETIC EFFECTS SUCH AS DIZZINESS, HEADACHE, NAUSEA.
PROLONGED EXPOSURE TO EXTREMELY HIGH CONCENTRATIONS OF VAPOR MAY
LEAD TO NARCOSIS, CARDIAC IRREGULARITIES, UNCONSCIOUSNESS OR DEATH.
SKIN(ACUTE): MAY CAUSE IRRITAT ION OR BURNING AS WELL AS FROSTBITE.
CHRONIC: PROLONGED OR REPEATED CONTACT MAY CAUSE DERMATITIS,
EXERCISE DUE CARE. EYE: MAY CAUSE IRRITATION. INGESTION(ACUTE): MAY
CAUSE NAUSEA OR VOMITING. (OTHER)
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:DO NOT USE EPINEPHRINE IN CONJUNCTION WITH THIS MATERIAL.
EYES: MAY BE AN EYE IRRITANT. FLUSH IMMEDIATELY WITH WATER FOR 15
MINUTES AND TAKE TO PHYSICIAN. SKIN: WASH AFFECTED AREA, TREAT FOR
FROSTBITE IF NECESSARY, AND CONSULT A PHYSICIAN IF IRRITATION
PERSISTS. INGESTION: CALL PHYSICIAN AND/OR TRANSPORT TO EMERGENCY
FACILITY IMMEDIATELY. DO NOT INDUCE VOMITING SO AS TO AVOID
ASPIRATION OF MATERIA L INTO THE LUNGS. INHALATION: REMOVE FROM
EXPOSURE AND RESTORE BREATHING. SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:N/D
Autoignition Temp:Autoignition Temp Text:N/E
Lower Limits:1.1%
Upper Limits:19.0%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:USE STANDARD FIRE FIGHTING TECHNIQUES TO FIGHT
FIRES INVOLVING THIS MATERIAL.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP SOURCE OF SPILL AS SOON AS POSSIBLE AND
NOTIFY APPROPRIATE PERSONNEL. BURM AROUND SPILL AREA TO PREVENT
SPILL FROM SPREADING. VENTILATE AREA. DO NOT FLUSH INTO SEWERS.
CREATE A TRENCH TO CONTAINMATERIALS. SPILLED MATERIALS MAY BE
CONTAINED USING SAND, CLAY, EARTH OR A COMMERCIAL ABSORBENT. DO NOT
PLACE MATERIALS BACK IN THEIR ORIGINAL CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL-VENTILATED
PLACE. STORE AT TEMPERATURES BELOW 120F. DO NOT STORE OR USE NEAR
HEAT, SPARKS, OR FLAMES. AVOID BREATHING VAPORS. VAPORS ARE HEAVIER
THAN AIR AND WILL COLLECT IN LOW AREAS AND OTHER CONFINED AREAS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A DUST RESPIRATORY WHEN WORKING WITH THE
ATOMIZED PRODUCT. BREATHING APPARATUS RECOMMENDED IF NECESSARY FOR
APPLICATION. REFER TO NIOSH PUBLICATION NO. 89-105 AND NIOSH
NO.87-116 SEE OSHA REQUIREM ENT UNDER 29CFR1910.1025 AND
29CFR1910.134.
Ventilation:LOCAL OR MECHANICAL TO MAINTAIN BELOW THEIR EXPOSURE
LIMITS.
PROTECTIVE SUIT.
Work Hygienic Practices:DO NOT TAKE INTERNALLY. AVOID CONTACT WITH EYES
AND CLOTHING. UPON CONTACT WITH SKIN OR EYES WASH OFF WITH WATER.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V2
Boiling Pt:B.P. Text:N/D
Melt/Freeze Pt:M.P/F.P Text:N/D
Decomp Temp:Decomp Text:N/D
Vapor Pres:N/D
Vapor Density:>AIR
Spec Gravity:0.9
VOC Pounds/Gallon:198
Evaporation Rate & Reference:>ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK LIQUID; STRONG ODOR; 93% VOLATILES BY WEIGHT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONCENTRATED NITRIC AND SULFURIC ACIDS, STRONG OXIDIZERS, HALOGENS AND
HALOGEN COMPOUNDS.
Stability Condition to Avoid:TEMPERATURES ABOVE 120F (49C)
Hazardous Decomposition Products:HYDROCHLORIC AND HYDROFLUORIC ACIDS,
CARBON MONOXIDE AND CARBON DIOXIDE, POSSIBLY CARBONYL HALIDES AT
HIGH TEMPERATURES.
=================== Toxicological Information===================
Toxicological Information:INHALATION OF HIGH CONCENTRATIONS MAY CAUSE
HEART IRREGULARITIES, UNCONSCIOUSNESS, OR DEATH. INTERACTIONS WITH
OTHER CHEMICALS THAT ENHANCE TOXICITY: DO NOT USE EPINEPHRINE IN
CONJUNCTION WITH THIS M ATERIAL. REPRODUCTIVE & DEVELOPMENTAL
TOXICITY: THERE ARE NO KNOWN OR REPORTED EFFECTS ON REPRODUCTIVE
FUNCTION OR FETAL DEVELOPMENT. MUTAGENICITY: THIS PRODUCT IS NOT
KNOWN TO BE MUTAGENIC.
===================== Ecological Information =====================
Ecological:AQUATIC TOXICITY: NONE KNOWN OR REPORTED.
==================== Disposal Considerations ====================
Waste Disposal Methods:SPILLED MATERIAL COLLECTED IN ABSORBENT MATERIAL
SHOULD BE TRANSFERRED TO STEEL DISPOSAL OR RECOVERY DRUMS. IF THIS
PRODUCT BECOMES A WASTE, IT DOES NOT MEET THE CRITERIA OF A
HAZARDOUS WASTE AS DEFIN ED UNDER 40 CFR 261. DISPOSE OF IN
ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS BY INCINERA
TION.
=================== MSDS Transport Information ===================
Transport Information:DOT SHIPPING NAME: CONSUMER COMMODITY. DOT
HAZARD CLASS: ORM-D. DOT PACKING GROUP: NONE. DOT REPORTABLE
QUANTITY: NONE FOUND IN 49 CFR 172.101.
===================== Regulatory Information =====================
SARA Title III Information:SECTION 302/304: REQUIRES EMERGENCY PLANNING
BASED ON THRESHOLD PLANNING QUANTITIES AND RELEASE REPORTING BASED
ON REPORTABLE QUANTITIES OF EXTREMELY HAZARDOUS SUBSTANCES LISTED
IN APPENDIX A OF 40 CF R 355. THERE ARE NO COMPONENTS OF THIS
MATERIAL WITH KNOWN CAS NUMBERS THAT ARE ON THE EHS LIST. SECTION
311 & 312: BASED UPON THE AVAILABLE INFORMATION, THIS MATERIAL
AND/OR COMPONENTS IS CLASSIFIED AS A HEALTH AND/OR PHYSICAL
HAZARDS ACCORDING TO SECTION 313 & 312. SECTION 313: THIS MATERIAL
DOES NOT CONTAIN CHEMICALS WITH KNOWN CAS NUMBERS SUBJECT TO THE
REPORTING REQUIREMENTS OF SARA TITLE I II, SECTION 313 AND 40 CFR
372.
Federal Regulatory Information:TOXIC SUBSTANCES CONTROL ACT: THE
COMPONENTS OF THIS PRODUCT ARE LISTED ON THE TSCA INVENTORY. THIS
MATERIAL DOES NOT CONTAIN CHEMICAL(S) WITH KNOWN CAS NUMBERS
CLASSIFIED AS HAZARDOUS SUBSTANCES SUB JECT TO THE REPORTING
REQUIREMENTS OF CERCLA (40 CFR 302) AND TO THE RELEASE REPORTING
REQUIREMENTS OF SARA (SECTION 302) BASED ON REPORTABLE QUANTITIES.
OSHA REGULATIONS (1910.1002 TO 1910.1050) PRE SENTED UNDER 29 CFR
1910 DO NOT APPLY TO THIS MATERIAL OR ITS COMPONENTS.
State Regulatory Information:THIS MATERIAL IS NOT KNOWN TO CONTAIN ANY
CHEMICALS CURRENTLY LISTED AS CARCINOGENS OR REPRODUCTIVE TOXINS
UNDER CALIFORNIA PROPOSITION 65 AT LEVELS THAT WOULD BE SUBJECT TO
THE PROPOSITION. CALIFORN IA SOUTH COAST AIR QUALITY MANAGEMENT
DISTRICT (SCAQMD) RULE 443.1 (VOC'S): THIS IS A VOC MATERIAL.
MASSACHUSETTS RIGHT TO KNOW SUBSTANCE LIST (MSL) (105 CMR 670.000):
HAZARDOUS SUBSTANCES ON THE MSL MUST BE IDENTIFIED WHEN PRESENT IN
MATERIALS AT LEVELS GREATER THAN STATE SPECIFIED CRITERION. PENN
SYLVANIA RIGHT TO KNOW HAZARDOUS SUBSTANCE LIST MOLYBDENUM
DISULFIDE, PROPYLENE GLYCOL N-BUTYL ETHER, 1,1-DIFLUOROETHANE.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AQ-701
CAGE:71229
Contract Num:SP0450-00-M-D465
CAGE:71229
Contract Num:SP0450-01-M-ZC92
CAGE:71229
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE
CAS:1310-73-2
RTECS #:WB4900000
OSHA PEL:2 MG/M3
ACGIH STEL:C2 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SODIUM NITRITE
CAS:7632-00-0
RTECS #:RA1225000
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:INHALATION: DAMAGE TO ENTIRE
RESPIRATORY TRACT.INGESTION: VOMITING, PROSTRATION, COLLAPSE.
CONSTRICTIVE SCARRING MAY RESULT. SKIN/EYES: CORROSIVE TO ALL
TISSUES.
Explanation of Carcinogenicity:NONE SPECIFIED BY MANUFACTURER.
Effects of Overexposure:INGESTION: VOMITING, PROSTRATION, COLLAPSE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE OR SKIN CONTACT:RINSE IN COOL, FLOWING WATER FOR 15
MINUTES. INGESTION: DRINK LARGE QUANTITIES OF WATER OR MILK TO
DILUTE ALKALI. DRINK DILUTE VINEGAR OR FRUIT JUICE TO NEUTRALIZE.
DO NOT IND UCE VOMITING. INHALATION: REMOVE TO FRESH AIR. SKIN:
IMMEDIATELY FLUSH WITH WATER FOR 15 MINUTES.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR SELF-CONTAINED
BREATHING APPARATUS IN THE POSITIVE MODE WITH A FULL FACEPIECE WHEN
THERE IS A POSSIBILITY OF EXPOSURE TO SMOKE, FUMES, OR HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NOT FLAMMABLE - EXTREME HEAT DECOMPOSES
PRODUCT TO OXIDES OF SULFUR.
================== Accidental Release Measures ==================
Spill Release Procedures:USE SODIUM BICARBONATE TO NEUTRALIZE, THEN
ABSORB IN SAND OR OTHER ABSORBENT MATERIAL. SCHOVEL INTO CLOSABLE
CONTAINER FOR DISPOSAL. WEAR PROTECTIVE EQUIPMENT. FLUSH RESIDUE
THOROUGHLY WITH WATER.
Neutralizing Agent:SODIUM BICARBONATE
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED DURING
TRANSPORT AND STORAGE. KEEP CLOSED WHEN NOT IN USE. AVOID
FREEZING. AVOID CONTACT WITH EYES, SKIN AND CLOTHING.
Other Precautions:FOR INDUSTRIAL USE ONLY. NEVER TASTE OR SWALLOW.
AVOID EYE CONTACT OR PROLONGED OR REPEATED SKIN CONTACT. WASH
THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED.
Ventilation:WORK IN WELL-VENTILATED AREAS.
Other Protective Equipment:WEAR GAUNTLETS AND APRON, ESPECIALLY IF
HANDLING LARGE QUANTITIES.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
FOR INDUSTRIAL USE ONLY. NEVER TASTE OR SWALLOW. AVOID EYE CONTACT OR
PROLONGED OR REPEATED SKIN CONTACT.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:=102.2C, 216.F
Spec Gravity:1.01
pH:11.0 - ..2
Solubility in Water:100%
Appearance and Odor:BRIGHT RED CLEAR LIQUID, SLIGHT ODOR.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
PRODUCT IN NEAT FORM IS CORROSIVE TO ALUMINUM, TIN, ZINC, AND ALLOYS OF
THOSE METALS. PRODUCT IN USE FORM IS NOT CORROSIVE.
Stability Condition to Avoid:AVOID REDUCING AGENTS SUCH AS CYANIDES.
Hazardous Decomposition Products:EXTREME THERMAL DECOMPOSITION MAY
PRODUCE NITROGEN AND SODIUM OXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:OSHA STD.-AIR: TWA 2 MG/M3 (SCP-W).
===================== Ecological Information =====================
Ecological:NO DATA PROVIDED BY MANUFACTURER
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:NO DATA PROVIDED BY MANUFACTURER
===================== Regulatory Information =====================
SARA Title III Information:NO DATA PROVIDED BY MANUFACTURER
Federal Regulatory Information:SODIUM HYDROXIDE AND SODIUM NITRITE ARE
BOTH LISTED IN EPA TSCA INVENTORY (1980).
State Regulatory Information:NO DATA PROVIDED BY MANUFACTURER
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:33 EXTREME LOW TEMPERATURE BEARING GREASE, LIGHT
Preparer's Name:JACK L. SHENEBERGER
CAGE:5D028
CAGE:5D028
CAGE:71984
CAGE:6U655
============= Composition/Information on Ingredients =============
Ingred Name:2,6-CIS-DIPHENYLHEXAMETHYLCYCLOTETRASILOXANE
CAS:33204-76-1
RTECS #:GZ4390000
Fraction by Wt: <0.02%
Other REC Limits:TWA 20 MICROGMS/M3
Ingred Name:PHENYLHEPTAMETHYLCYCLOTETRASILOXANE
CAS:10448-09-6
RTECS #:GZ4392000
Fraction by Wt: <0.3%
Other REC Limits:TWA 200 MICROGMS/M3
Ingred Name:LITHIUM SOAP THICKENER
CAS:4485-12-5
RTECS #:WI4370000
Fraction by Wt: 18%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DIRECT EYE CONTACT MAY CAUSE TEMPORARY
DISCOMFORT WITH MILD REDNESS AND DRYNESS SIMILAR TO WINDBURN. A
SINGLE RELATIVELY SHORT EXPOSURE CAUSE NO KNOWN ADVERSE SKIN
EFFECT. SEVERAL PROLONGED REPEAATED EXPOSURES MAY IRRITATE SKIN.
INHALATIONIRRITATES RESPIRATORY PASSAGES. SWALLOWING LARGE AMOUNTS
MAY CAUSE DISCOMFORT.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH WATER. SKIN: WIPE OFF AND WASH
WITH MILD SOAP AND WATER SOLUTION OR "WATERLESS" CLEANER.
INHALATION: NO FIRST AID SHOULD BE NEEDED. INGESTION: NO FIRST AID
SHOULD BE NEEDE D.
===================== Fire Fighting Measures =====================
Flash Point Method:OC
Flash Point:>250F,>121C
Extinguishing Media:WATER FOG, DRY CHEMICAL, FOAM, CARBON DIOXIDE
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING SHOULD BE WORN IN FIGHTING FIRES INVOLVING
CHEMICALS.
Unusual Fire/Explosion Hazard:NONE KNOWN TO DOW CORNING.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE PRODUCT AND USE ABSORBENT MATERIAL TO
TAKE CARE OF ANY OIL-LIKE RESIDUES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE REASONABLE CARE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:MECHANICAL (GENERAL) VENTILATION: RECOMMENDED.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
TRACESS OF BENZENE AND FORMALDEHYDE (CARCINOGENS) MAY FORM IF HEATED IN
AIR ABOVE 300F. THE CYCLOTETRASILOXANES CONTAINED IN PRODUCT ARE
ESTROGEN-LIKE CHEMICALS. ANIMAL STUDIES INDICATE ESTROGENS MAY
CAUSE CANCER AND ADVERSE REPRODUCTIVE EFFECTS AFTER PROLONGED
EXPOSURE. NO INJURY SHOULD OCCUR DURING REASONABLE USE.
================== Physical/Chemical Properties ==================
HCC:V6
Vapor Pres:< 5
Spec Gravity:1.05
Solubility in Water:NEGLIGIBLE
Appearance and Odor:VERY LITTLE ODOR, GREASE, LIGHT BEIGE-TAN.
Percent Volatiles by Volume:<5 %
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL CAN CAUSE A REACTION.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:LITHIUM OXIDE, SILICON DIOXIDE, CARBON
DIOXIDE AND TRACES OF INCOMPLETELY BURNED CARBON PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DOW CORNING SUGGESTS THAT ALL LOCAL, STATE AND
FEDERAL REGULATIONS CONCERNING HEALTH AND POLLUTION BE REVIEWED TO
DETERMINE APPROVED DISPOSAL PROCEDURES. CONTACT DOW CORNING IF
THERE ARE ANY DISPOSAL QUESTIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:42328 START REAGENT FOR ETHANOL
Kit Part:Y
CAGE:1Z582
CAGE:1Z582
CAGE:66002
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM METHANESULFONATE
CAS:2386-57-4
Fraction by Wt: 29.52%
Ingred Name:1,2-PROPANEDOIL, 3-MERCAPTO-
CAS:96-27-5
RTECS #:TY8140000
Fraction by Wt: 2.5%
Ingred Name:SODIUM CITRATE
CAS:6132-04-3
Fraction by Wt: 1.47%
Ingred Name:SODIUM AZIDE, AZIDE
CAS:26628-22-8
RTECS #:VY8050000
Fraction by Wt: 0.1%
Other REC Limits:0.1 PPM
ACGIH TLV:C 0.29 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 200 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN
ABSORPTION/INGESTION OF REAGENTS CONTAINING SODIUM AZIDE MAY CAUSE
A DECREASE IN BLOOD PRESSURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, SEVERE HEADACHES.
Medical Cond Aggravated by Exposure:INDIVIDUALS W/HYPERSENSITIVITY TO
THIOGLYCEROL.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER. SKIN: FLUSH W/PLENTY OF WATER
& WASH AREA W/SOAP & WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS & FULL
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:DISCHARGE OF LARGE AMOUNTS OF SODIUM
AZIDE TO LEAD/COPPER SEWER DRAINS COULD PROMOTE BUILDUP OF
POTENTIALLY EXPLOSIVE METAL AZIDES.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/ABSORBENT MATERIAL. PLACE ABSORBENTS
INTO SUITABLE LABELED CONTAINER. WASH AREA W/SOAPY WATER & FLUSH
WASH TO SEWER W/LARGE AMOUNTS OF WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE PROPER PERSONAL PROTECTIVE
EQUIPMENT. KEEP REAGENT BOTTLES CLOSED WHEN NOT IN USE.
Other Precautions:AVOID CONTACT W/EYES & SKIN. DON'T EAT, DRINK/SMOKE
WHEN HANDLING. DON'T PIPET BY MOUTH, USE MECHANICAL PIPETTING
DEVICE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED
Ventilation:MECHANICAL (GENERAL): RECOMMENDED
Other Protective Equipment:LAB COAT
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. FOLLOW GOOD
LABORATORY PRACTICES. REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
ORAL LD50 IS FOR METHANESULFONIC ACID.
================== Physical/Chemical Properties ==================
pH:6.8
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS TO FAINT YELLOW SOLUTION
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HEAVY METALS, ACIDS, ACID CHLORIDES
Hazardous Decomposition Products:TOXIC PRODUCTS FROM THERMAL
DECOMPOSITION
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL/INCINERATE IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:COUMARIN 30
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:COUMARIN 30
CAS:41044-12-6
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THE TOXICOLOGICAL PROPERTIES OF THIS
MATERIAL HAVE NOT BEEN FULLY INVESTIGATED. EXERCISE APPROPRIATE
PROCEDURES TO PREVENT OPPORTUNITIES FOR DIRECT CONTACT W/SKIN OR
EYES OR TO PREVENT INHALATION.
Explanation of Carcinogenicity:MANUFACTURER GAVE NO INFORMATION ABOUT
CARCINOGENICITY. HMIS DOES NOT EXPECT IT TO BE CARCINOGENIC.
Effects of Overexposure:MFR GAVE NO INFORMATION ON MSDS.
Medical Cond Aggravated by Exposure:MFR GAVE NO INFORMATION ON MSDS.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. TREAT SYMPTOMATICALLY. IF
SYMPTOMS ARE PRESENT, GET MEDICAL ATTENTION. EYES:FLUSH W/PLENTY OF
WATER FOR 15 MIN. GET IMMEDIATE MEDICAL ATTENTION. SKIN:FLUSH
W/WATER FOR 15 MIN. GET MEDICAL ATTENTION IF SYMPTOMS ARE PRESENT
AFTER WASHING. INGESTION:DRINK 1-2 GLASSES OF WATER. GET IMMEDIATE
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CARBON DIOXIDE
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS. THIS MATERIAL IN SUFFICIENT
QUANTITY & REDUCED PARTICLE SIZE MAY CREATE A DUST EXPLOSION.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP MATERIAL & PACKAGE FOR SAFE FEED TO
AN INCINERATOR.
Neutralizing Agent:MFR GAVE NO INFORMATION ON MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM CONTACT W/OXIDIZING
MATERIALS.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH APPROVED DUST RESPIRATOR SHOULD BE WORN
IF NEEDED.
Ventilation:GOOD GENERAL ROOM VENTILATION SHOULD BE USED. LOCAL EXHAUST
MAY BE NEEDED.
Other Protective Equipment:MFR GAVE NO INFORMATION ON MSDS.
Work Hygienic Practices:MFR:?.HMIS:USE GOOD CHEMICAL HYGIENE
PRACTICES. AVOID CONTACT IF AT ALL POSSIBLE. WASH THOROUGHLY AFTER
HANDLING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NONE
Melt/Freeze Pt:M.P/F.P Text:428F,220C
Vapor Pres:NEGLIGLBLE
Spec Gravity:NOT AVAILABLE
Evaporation Rate & Reference:NEGLIGLBLE
Solubility in Water:NEGLIGLBLE
Appearance and Odor:YELLOW CRYSTALLINE SOLID; ODORLESS
Percent Volatiles by Volume:NEGLIG
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:MFR GAVE NO INFORMATION ON MSDS.
Hazardous Decomposition Products:COMBUSTION WILL PRODUCE CARBON DIOXIDE
& PROBABLY CARBON MONOXIDE. OXIDES OF NITROGEN MAY ALSO BE PRESENT.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE BY INCINERATION OR CONTRACT W/LICENSED
CHEMICAL WASTE DISPOSAL AGENCY. DISCARGE, TREATMENT OR DISPOSAL MAY
BE SUBJECT TO FEDERAL, STATE OR LOCAL LAWS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MAXCAST CASTING TAPE 202-52/53/54/55
CAGE:8S126
CAGE:8S126
============= Composition/Information on Ingredients =============
Ingred Name:DIPHENYLMETHANE DIISOCYANATE (MDI) (COMPONENT OF FABRIC
COATING)
RTECS #:NQ8805000
ACGIH TLV:0.02 PPM
===================== Hazards Identification =====================
Effects of Overexposure:WHEEZING COUGH, RESPIRATORY TRACT IRRITATION,
SHORTNESS OF BREATH.
======================= First Aid Measures =======================
First Aid:INHALATION OF VAPOR: REMOVE TO UNCONTAMINATED AREA, ADMINSTER
OXYGEN. SKIN CONTACT: WASH AFFECTED AREAS THOROUGHLY WITH
SOAP/WATER. EYE CONTACT: FLUSH WITH LOW PRESSURE WATER 15 MINUTES,
OBTAIN MEDICA L HELP.
===================== Fire Fighting Measures =====================
Flash Point:350F
Extinguishing Media:DRY CHEMICAL, CO2, CHEMICAL FOAM, WATER SPRAY
Fire Fighting Procedures:WEAR SCBA. WATER COOL POUCHES OF PRODUCT
EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION OF ISOCYANATES CAN
CAUSE A PRESSURE BUILD UP IN SEALED POUCHES.
================== Accidental Release Measures ==================
Spill Release Procedures:ACETONE OR ALCOHOL MAY BE USED TO CLEAN
NON-POLYMERIZED POLYMER FROM SURFACES.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T PUNCTURE POUCH. STORE AT OR
BELOW ROOM TEMPERATURE.
Other Precautions:A CURED CAST CONTAINS NO FREE ISOCYANATE OR OTHER
TOXIC MATERIAL. POLYMERIZATION OF THE CASTING TAPE BEGINS AS SOON
AS THE PCH IS OPENED AND THE PRODUCT IS EXPOSED TO AMBIENT
HUMIDITY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AN AIR SUPPLIED RESP: AIR-PURIFYING RESP FOR
SHORT TERM EXPOSURE.
Ventilation:USE VENTILATION TO KEEP BELOW TLV.
Other Protective Equipment:APPLY PADDING AND/OR STOCKINETTE UNDER ALL
CASTS.
Supplemental Safety and Health
MSDS DATED: 7 NOV 85.
================== Physical/Chemical Properties ==================
Vapor Pres:<10
Vapor Density:8.5
Spec Gravity:>1.0
Solubility in Water:INSOLUBLE
Appearance and Odor:FIBERGLASS FABRIC W/CLEAR URETHANE PREPOLYMER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER OR ALCOHOL UNLESS POLYMERIZATION DESIRED. _
Stability Condition to Avoid:STORE AT OR BELOW ROOM TEMPERATURE FOR
MAXIMUM SHELF LIFE.
Hazardous Decomposition Products:CO, AMINES, OXIDES OF NITROGEN, TRACES
OF HCN AND MDI
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:USA 320-15
CAGE:JO533
CAGE:0AZS7
CAGE:JO533
============= Composition/Information on Ingredients =============
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:NICKEL (SARA 313) (CERCLA) (MFR'S CAS #7440-02-2)
CAS:7440-02-0
RTECS #:QR5950000
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
OSHA PEL:10 PPM
ACGIH TLV:10 PPM
Ingred Name:MANGANESE (SARA 313)
CAS:7439-96-5
RTECS #:OO9275000
OSHA PEL:5 MG/M3 DUST, C
ACGIH TLV:5 MG/M3 DUST
Ingred Name:CHROMIUM (SARA 313) (CERCLA)
CAS:7440-47-3
RTECS #:GB4200000
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:NIOBIUM; (COLUMBIUM)
CAS:7440-03-1
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CALCIUM FLUORIDE
CAS:7789-75-5
RTECS #:EW1760000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM SILICATE
CAS:1344-09-8
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CLAY (KAOLIN); (ALUMINUM SILICATES)
CAS:1332-58-7
RTECS #:GF1670500
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST
Ingred Name:POTASSIUM SILICATES
CAS:1312-76-1
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CRYOLITE
CAS:15096-52-3
RTECS #:WA9625000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ZIRCONIUM SILICATES
CAS:7440-42-6
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:COPPER (SARA 313) (CERCLA)
CAS:7440-50-8
RTECS #:GL5325000
OSHA PEL:0.1MG/M3 FUME;1 DUST
ACGIH TLV:0.2 MG/M3 FUME
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (QUARTZ)
CAS:14808-60-7
RTECS #:VV7330000
OSHA PEL:N/K
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:SUPDAT: BE REACHED BEFORE LIM OF 5 MG/M3 FOR GEN WELDING
FUMES IS REACHED. WATCH CR(VI) LEVEL. GASEOUS RXN PRODS(ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:MAY INCL CO & CO*2. OZONE & NITROGEN OXIDES MAY BE
FORMED BY RADIA FROM ARC. CONTACT NEHC FOR MORE INFO .
RTECS #:9999999ZZ
Ingred Name:EXPLAN OF CARCIN:CRYSTALLINE-QUARTZ:IARC MONO, V 68,
1997:GRP 1. NTP 7TH ANNUAL RPT ON CARCINS, 1994:ANTIC TO BE CARCIN.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP: IN LUNG) & IS BELIEVED TO AFFECT PULM
FUNC. REPETITIVE EXPOS TO FLUORIDE FUMES &/OR GASES MAY (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21: CAUSE EXCESS CALCIFICATION OF BONES & LIGAMENTS OF
RIBS, PELVIS & SPINAL COLUMN. CHROMIUM(VI) CMPDS MAY (ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22:CAUSE ULCERATION & PERFORATION OF NASAL SEPTUM &
LIVER & KIDNEY DMG. REPETITIVE OVEREXP TO NICKEL OXIDES (ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23: MAY LEAD TO LUNG FIBROSIS OR PNEUMOCONIOSIS. ARC
RAYS CAN INJURE EYES & BURN SKIN. ELEC SHOCK CAN KILL.
RTECS #:9999999ZZ
Ingred Name:EYE PROT:& FULL LNGTH FSHLD W/FILTER LENS SHADE
#12-14/DARKER. SHIELD OTHERS BY PROVIDING SCREENS & FLASH GOGGS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE OVEREXP TO WELDING FUMES MAY
RSLT IN DISCOMFORT SUCH AS DIZZ, NAUS OR DRYNESS/IRRIT OF NOSE,
THROAT/EYES. INHAL OF EXTREMELY HIGH LEVELS OF FLUORIDES MAY CAUSE
ABDOM PAIN, DIARR, MUSC WEAK & CON VLS. CONTINUED INHAL COULD CAUSE
UNCON & DEATH. CHROMIUM (VI) CMPDS PRESENT IN FUME MAY CAUSE SEV
IRRIT(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NICKEL: IARC MONO, VOL 49, PG 257,
1990:GRP 2B. NTP 7TH ANNUAL RPT ON CARCINS, 1994:ANTIC TO BE
CARCIN. SILICA, (ING 20)
Effects of Overexposure:HLTH HAZ: OF BRONCH TUBES & LUNGS. INGEST OF
CHROMIUM (VI) SALTS MAY CAUSE INJURY/DEATH. CHROMIUM(VI) CMPDS MAY
BURN EYES. CHROMIUM CMPDS MAY CAUSE ALLERGIC RXNS. NICKEL OXIDES IN
FUME MAY CAUSE TIGHT NESS AROUND CHEST, FEVER & ALLERGIC RXNS.
CHRONIC OVEREXP TO WELDING FUMES CAN LEAD TO SIDEROSIS (IRON
DEPOSITS (ING 21)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMED . EYES: IMMED FLUSH W/POTABLE WATER FOR
A MINIMUM OF 15 MINUTES, SEEK ASSISTANCE FROM MD . SKIN: FLUSH
W/COPIOUS AMTS OF WATER. CALL MD . CALL FOR MED ASSISTANC E. USE
FIRST AID PROCEDURERS RECOM BY AMERICAN RED CROSS. IF BREATHING IS
DFCLT, GIVE OXYGEN. IF NOT BREATHING USE CPR. CONSULT MD IF
IRRITATION OF EYES & SKIN OR FLASH BURNS DEVELOP AFTER EXPOSURE.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NON-FLAMMABLE: WELDING ARC AND SPARKS CAN
IGNITE COMBUSTIBLES. SEE Z-49.1 SAFETY IN WELDING & CUTTING,
PUBLISHED BY AWS, 550 NW LEJEUNE RD, MIAMI, FL 33126.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:READ & UNDERSTAND MFR'S INSTRUCTIONS &
PREC LABEL ON PROD. ADVISE WELDERS TO KEEP THEIR HEAD OUT OF FUMES.
SEE ANSI Z49.1 & 29 CFR 1910 FOR MORE INFO.
Other Precautions:ONE METHOD OF DETERMINING COMPOSITION & QTY OF FUMES
& GASES TO WHICH WORKERS ARE EXPOSED IS TO TAKE AIR SAMPLE FROM
INSIDE WELDER'S HELMET WHILE WORN OR IN WORKER'S BREATHING ZONE.
SEE ANSI/AWS F1.1 AVAIL FROM AMERICAN WELDING SOCIETY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRABLE FUME RESPIRATOR OR
AIR SUPPLIED RESPIRATOR WHEN WELDING IN CONFINED SPACE OR GENERAL
WORK AREA WHERE LOCAL EXHAUST AND/OR VENTILATION DOES NOT KEEP
EXPOSURE BELOW THE THR ESHOLD LIMIT VALUE.
Ventilation:USE PLENTY OF VENT &/OR LOC EXHST AT ARC TO KEEP FUMES &
GASES BELOW TLV W/IN WORKER'S BRTHG ZONE & GEN WORK AREA.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . ARM
PROTECTORS, APRON, HATS, SHOULDER PROT & DARK SUBSTANTIAL CLTHG.
Work Hygienic Practices:TRAIN WELDER NOT TO ALLOW ELEC LIVE PARTS TO
GROUND.
Supplemental Safety and Health
HAZ DECOMP PRODS: WELDED, PROCS FOLLOWED & ELECTRODES USED. REASONABLE
EXPECTED FUME CONSTITUENTS OF PROD WOULD INCL: COMPLEX OXIDES OF
ALUMINUM, IRON, MANGANESE, SILICON, TITANIUM, CHROMIUM, NICKEL,
CALCIUM, COLUMBIAN, MOLYBDENUM & COPPER. FLUORIDES WILL ASLO BE
PRESENT. FUME LIM FOR (CR(VI)(0.05 MG/M3) MAY (ING 18)
================== Physical/Chemical Properties ==================
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WELDING FUMES & GASES CANNOT BE
CLASSIFIED SIMPLY. COMPOSITION & QTY OF FUMES & GASES DEPEND ON
METAL BEING (SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER
OR LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER APPROVED BY
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DURSBAN 4E INSECTICIDE
CAGE:EO044
CAGE:96717
CAGE:EO044
============= Composition/Information on Ingredients =============
Ingred Name:CHLORPYRIFOS
CAS:2921-88-2
RTECS #:TF6300000
Fraction by Wt: 44.9%
OSHA PEL:S, 0.2 MG/M3
ACGIH TLV:S,0.2 MG/M3/0.6 STEL
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:XYLENES (O-,M-,P- ISOMERS)
CAS:1330-20-7
RTECS #:ZE2100000
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;8990
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PROPRIETARY EMULSIFIERS
OSHA PEL:NOT ESTABLISHED.
ACGIH TLV:NOT ESTABLISHED.
Ingred Name:NAPHTHA, LIGHT AROMATIC
CAS:64742-95-6
Other REC Limits:NONE SPECIFIED
Ingred Name:1,2,4-TRIMETHYLBENZENE (SARA III)
CAS:95-63-6
RTECS #:DC3325000
Other REC Limits:NONE SPECIFIED
OSHA PEL:25 PPM
ACGIH TLV:25 PPM; 9192
Ingred Name:CUMENE (SARA III)
CAS:98-82-8
RTECS #:GR8575000
Other REC Limits:NONE SPECIFIED
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 50 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 ORAL RAT(MALE=940,FEMALE=530) MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-EYE:MAY CAUSE MODERATE CORNEAL
INJURY.SKIN:PROLONGED/REPEATED CONTACT MAY CAUSE SEVERE
IRRITATION,BURN.IF ABSORBED IS HARMFUL.ORAL:HIGH DOSE MAY CAUSE
INJURY.ASPIRATION MAY CAUSE LUNG DAMAGE/DEA TH.INHALED:MAY
CAUSE,IRRITATION,HEADACHE,DIZZINESS,COMA.CHRONIC-DIZZINESS,INCOORDI
NATION,LIVER & KIDNEY EFFECTS.
Effects of Overexposure:EYE & RESPIRATORY TRACT IRRITATION, FEELING OF
INCREASED BODY HEAT, CENTRAL NERVOUS SYSTEM EFFECTS SUCH AS
HEADACHE, DIZZINESS, INCOORDINATION, DROWSINESS, UNCONSCIOUSNESS.
EXCESSIVE EXPOSURE MAY PROD UCE ORGANOPHOSPHATE TYPE
CHOLINESTERASEINHIBITION WITH NAUSEA, DIARRHEA, SWEATING, BLURRED
VISION, TEARING&CONVULSIONS.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS OR EYE PROBLEMS OR IMPAIRED LIVER, KIDNEY OR RESPIRATORY
FUNCTION MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THE SUBSTANCE.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST.SKIN:WASH WITH SOAP
& WATER.EYE:FLUSH WITH WATER FOR 15 MINUTES,HOLDING EYELIDS
OPEN.INHALED:REMOVE TO FRESH AIR & PROVIDE OXYGEN/CPR IF
NEEDED.ORAL:DO NOT IN DUCE VOMITING.IF VOMITING OCCURS,KEEP HEAD
BELOW HIPS DUE TO ASPIRATION HAZARD.CALL PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:106F, 41C
Lower Limits:1
Upper Limits:6 (XYLENE)
Extinguishing Media:FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:FOAM EXTINGUISHING SYSTEM IS PREFERRED BECAUSE
UNCONTROLLED WATER CAN SPREAD POSSIBLE CONTAMINATION. USE POSITIVE-
PRESSURE SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:TOXIC IRRITATING GASES MAY BE FORMED
UNDER FIRE CONDITIONS. VIOLENT RUPTURE DUE TO OVER PRESSURIZATION
MAY OCCUR AT TEMPERATURES GENERATED DURING A FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SPILLS WITH AN ABSORBENT MATERIAL SUCH
AS HAZORB, ZORBALL, OR DIRT. THOROUGHLY WASH BODY AREAS WHICH COME
INTO CONTACT WITH THIS PRODUCT. CONTAIN SPILL TO KEEP OUT OF
SEWERS. FOR LARGE SPILLS, CONSULT MANUFACTURER. RQ OF CHLORPYRIFOS
= 1 LB.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE-KEEP AWAY FROM HEAT & FLAME.
Other Precautions:SEE LABEL. KEEP OUT OF REACH OF CHILDREN. DO NOT
SWALLOW. DO NOT GET IN EYES, ON SKIN OR ON CLOTHING. AVOID
BREATHING MIST OR VAPORS. HANDLE CONCENTRATE IN VENTILATED AREA.
WASH THOROUGHLY AFTER HANDL ING. KEEP AWAY FROM FOOD & WATER
SUPPLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ATMOSPHERIC LEVELS SHOULD BE MAINTAINED BELOW
THE EXPOSURE GUIDELINE. WHEN RESPIRATORY PROTECTION IS REQUIRED FOR
CERTAIN OPERATIONS, USE AN APPROVED AIR-PURIFYING RESPIRATOR. USE
AN APPROVED POSITIVE -PRESSURE SCBA FOR EMERGENCY CONDITIONS.
Ventilation:CONTROL AIRBORNE CONCENTRATIONS BELOW THE EXPOSURE
GUIDELINE. USE ONLY WITH ADEQUATE VENTILATION. LOCAL MAY BE
REQUIRED.
Other Protective Equipment:PERMEATION-RESISTANT CLOTHING. BOOTS, APRON
OR FULL-BODY SUIT AS REQUIRED. EYE WASH & SAFETY SHOWER IN WORK
AREA.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. DEPENDING ON
DEGREE OF EXPOSURE OF PERSONNEL. CONSIDER MONITORING BLOOD
CHOLINESTERASE.
Supplemental Safety and Health
FORMULA CHANGED. FOR PREVIOUS FORMULATION, SEE P/N A OR B SAME NSN. FOR
HEALTH & SAFETY INFORMATION ON END-USE DILUTIONS OF UP TO 1% OF
DURSBAN INSECTICIDES, SEE THE HEALTH & SAFETY FACT SHEET, FORM #
135-1270-88, AVAILABLE FROM THE DOW CHEMICAL COMPANY.
================== Physical/Chemical Properties ==================
HCC:T5
Boiling Pt:B.P. Text:290F/143C
Decomp Temp:Decomp Text:>320F,>160C
Vapor Pres:<10 @ 25C
Spec Gravity:1.079
Solubility in Water:EMULSIFIABLE
Appearance and Odor:YELLOW LIQUID, SOLVENT-TYPE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:AVOID HEATING ABOVE 122F(50C). UNDERGOES
EXOTHERMIC DECOMPOSITION AT APPROXIMATELY 266F(130C).
Hazardous Decomposition Products:UNDER FIRE CONDITIONS, HYDROGEN
CHLORIDE, ETHYL SULFIDE, DIETHYL SULFIDE AND NITROGEN OXIDES CAN BE
FORMED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT CONTAMINATE FOOD, FEED, OR WATER BY
STORAGE OR DISPOSAL. PESTICIDE WASTES ARE TOXIC. IMPROPER DISPOSAL
OF EXCESS PESTICIDE, SPRAY MIXTURE, OR RINSATE IS A VIOLATION OF
FEDERAL LAW. DISPOSE OF W ASTE IN ACCORDANCE WITH LABEL
INSTRUCTIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:WALL KOTE ALKYD SEMI GLOSS PAINT, ACCENT BA
CAGE:75734
CAGE:75734
CAGE:55652
============= Composition/Information on Ingredients =============
Ingred Name:FIRST AID PROC:SPONT, KEEP HEAD BELOW HIPS TO PREVENT
ASPIRATION OF LIQUID INTO THE LUNGS. GET MEDICAL ATTENTION.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:ASSURE CONFORMITY W/APPLIC GOVT REGS. CONTINUE
TO OBSERVE PRECS FOR VOLAT, COMBUST VAPS FROM ABSORBED MATL.
RTECS #:9999999ZZ
Ingred Name:CALCIUM CARBONATE. PEL:15 MG/M3 TDUST; 5 MG/M3 RDUST
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 3.7-8%
OSHA PEL:SEE INGREDIENT NAME
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CLAY (KAOLIN); (KAOLIN). PEL:10 MG/M3 TDUST; 5 MG/M3 RDUST
CAS:1332-58-7
RTECS #:GF1670500
Fraction by Wt: 9.1-9.3%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9293
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 23.8-29%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9293
Ingred Name:SYNTHETIC RESIN; (SYNTHETIC RESIN COMPLEX). %
(WT):33.1-48.6
Fraction by Wt: SEE ING
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 3.4-27%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:VOLATILE ORGANIC COMPOUNDS: 4.15 POUNDS/GALLON
RTECS #:9999999VO
Ingred Name:SUPP DATA: SKIN:PRLNGD/RPTD CONT CAN CAUSE MOD IRRIT,
DEFATTING &/OR DERM. EYES:CAN CAUSE SEV IRRIT, REDNESS, (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:TEARING & BLURRED VISION. INGEST:CAN CAUSE GI IRRIT,
NAUS, VOM & DIARR. ASPIR OF MATL INTO LUNGS CAN CAUSE (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:CHEM PNEUMONITIS WHICH CAN BE FATAL. MISC TOX
INFO:HLTH STUDIES HAVE SHOWN THAT MANY PETROLEUM HYDROCARB (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:SYNTHETIC LUBRICANTS POSE POTNTL HUMAN HLTH RISKS
WHICH MAY VARY FROM PERS TO PERS. AS A PREC, EXPOS TO (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:LIQS/VAPS/MISTS/FUMES SHOULD BE MINIMIZED. PROD
CONTAINS CRYSTALLINE SILICA (CS) WHICH IS CONSIDERED A (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:HAZ BY INHAL & PROBABLY CARCIN FOR HUMANS. CS CAN
ALSO CAUSE SILICOSIS, A NONCANCEROUS LUNG DISEASE. (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:PIGMENT DUST WOULD NOT NORMALLY BE ENCOUNTERED WHEN
HNDLNG A PACKAGED PAINT PROD CONTAINING PRE-WETTED (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:PIGMENT. PROPER NIOSH/MSHA APPRVD RESP PROT SHOULD
BE WORN WHEN SANDING DRIED PAINT FILM DUE TO PRESENCE OF CS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL RAT) >5 G/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL:EXCESSIVE INHAL OF VAPS CAN
CAUSE NASAL & RESP IRRIT, DIZZ, WEAK, FATIGUE, NAUS & HDCH. HIGH
VAP CONC MAY RESLT IN CNS DEPRESS. LAB ANIMAL STUDIES HAVE SHOWN
THAT PRLNGD/RPTD EXPOS TO LIGHT HYDR OCARBON VAPS IN SAME NAPHTHA
BOILING RANGE AS PROD CAN PRDCE ADVERSE KIDNEY EFTS IN MALE RATS.
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:CRYSTALLINE SILICA: GROUP 2A (IARC)
Effects of Overexposure:HLTH HAZ:HOWEVER, THESE EFTS WERE NOT OBSERVED
IN SIMILAR STUDIES W/FEMALE RATS & MALE/FEMALE MICE & IN LIMITED
STUDIES W/OTHER ANIMALS. IN A NUMBER OF HUMAN STUDIES, THERE WAS NO
CLININAL EVID OF SUC H EFTS AT NORM OCCUP LEVELS. IT IS HIGHLY
UNLIKELY THAT KIDNEY EFTS OBSERVED IN MALE RATS HAVE SIGNIFICANT
(SUPP DATA)
Medical Cond Aggravated by Exposure:HIGH VAPOR CONC (>1000 PPM) ARE
IRRITATING TO EYES & RESPIRATORY TRACT. MAY CAUSE HDCH, DIZZ, ARE
ANESTH, & MAY HAVE OTHER CNS EFFECTS INCLUDING DEATH.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR & PROVIDE OXYGEN IF BRTHG IS DFCLT.
IF BRTHG STOPS, BEGIN ARTF RESP & SEEK MD IMMED. SKIN:REMOVE
CONTAMD CLTHG/SHOES. FLUSH W/WATER. FOLLOW BY WASHING W/SOAP &
WATER. IF IRRI T OCCURS, GET MD. DO NOT REUSE CLTHG UNTIL CLEANED.
EYES:FLUSH W/CLEAN WATER FOR AT LEAST 15 MINS OR UNTIL IRRIT
SUBSIDES. IF IRRIT PERSISTS, CALL MD. INGEST:DO NOT INDUCE VOM. IF
VOM OCCURS (ING 15)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:104F,40C
Lower Limits:0.9%
Upper Limits:6%
Extinguishing Media:USE DRY CHEMICAL, FOAM OR CO*2. WATER MAY BE INEFT,
BUT WATER SHOULD BE USED TO KEEP FIRE EXPOSED CONTRS COOL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. IF LEAK/SPILL HAS IGNITED, USE WATER SPRAY TO DISPERSE VAPS &
PROT MEN ATTEMPTING TO STOP LEAK.(SUPP DATA)
Unusual Fire/Explosion Hazard:VAPS ARE HVR THAN AIR & MAY TRAVEL ALONG
GROUND OR BE MOVED BY VENT & IGNITED BY HEAT, PILOT LIGHTS, OTHER
FLAME & IGNIT SOURCES AT LOCATIONS DISTANT (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:ELIM IGNIT SOURCES (FLARES/FLAMES INCL PILOT
LIGHTS/ELEC SPRKS). RECOVER FREE PROD. ADD SAND/EARTH/OTHER
SUITABLE ABSORB TO SPILL AREA. MINIMIZE SKIN CONT. VENT CONFINED
SPACES. KEEP PROD OUT OF SEWER S/WATERCOURSES BY DIKING/IMPOUNDING
(ING 16)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:THE USE OF RESPIRATORY PROTECTION DEPENDS ON
VAPOR CONCENTRATION ABOVE THE TIME WEIGHTED TLV: USE NIOSH/MSHA
APPROVED RESPIRATOR.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL) &/OR LOCAL EXHAUST
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:DO NOT EAT, DRINK OR SMOKE WHILE USING THIS
PRODCUT. THOROUGHLY WASH HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health
FIRE FIGHT PROC:MINIMIZE BRTHG GASES, VAPS, FUMES OR DECOMP PRODS.
AVOID SPREADING BURNING LIQ W/WATER USED FOR COOLING. EXPLO
HAZ:FROM HNDLNG POINT. NEVER USE WELDING/CUTTING TORCH ON/NEAR
CONTR (EVE N EMPTY) BECAUSE VAPS MAY IGNITE. EFTS OF
OVEREXP:IMPLICATIONS FOR HUMANS AT/BELOW RECOM VAP LIMITS IN
WORKPLACE.(ING 7)
================== Physical/Chemical Properties ==================
HCC:F4
Vapor Pres:2 @ 20F
Vapor Density:4.9
Spec Gravity:1.03
Evaporation Rate & Reference:0.1 (BUTYL ACETATE=1)
Solubility in Water:<0.1%
Appearance and Odor:VISCOUS LIQUID.
Percent Volatiles by Volume:62.3
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS OR BASES & SELECTED AMINES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:THERMAL DECOMPOSITION IN THE PRESENCE
OF AIR MAY YIELD CARBON MONOXIDE &/OR CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF PRODUCT IN ACCORDANCE W/APPLICABLE
LOCAL, COUNTY, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EPOXY COATING MIL-C-2275OD #24084 PTB
Kit Part:Y
CAGE:DO668
CAGE:93981
CAGE:DO668
============= Composition/Information on Ingredients =============
Ingred Name:POLYMERS OF EPOXY RESIN AND BISPHENOL A
CAS:25036-25-3
Fraction by Wt: 30-35%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 (TOTAL DUST)
ACGIH TLV:5 MG/M3 (TOTAL DUST)
Ingred Name:1-METHOXY-2-PROPANOL (SARA 313) (VAPOR PRESSURE 12.50 MM HG
@ 25 C) (LEL 1.60 @ 25 C)
CAS:107-98-2
RTECS #:UB7700000
Fraction by Wt: 10-15%
Other REC Limits:NONE SPECIFIED
ACGIH TLV:100 PPM 150 PPM STEL
Ingred Name:YELLOW IRON OXIDE
CAS:20344-49-4
Fraction by Wt: 10-15%
Other REC Limits:NONE SPECIFIED
OSHA PEL:10.00 MG/M3
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 1-5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:MOLYBDATED LEAD CHROMATE (SARA 313)
CAS:12656-85-8
RTECS #:QA4600000
Fraction by Wt: 1-5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.05 MG/M3 AS PB
ACGIH TLV:0.05 MG/M3 AS CR
Ingred Name:LEAD (SARA 313)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.05 MG/M3
ACGIH TLV:0.15 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CHROMIUM (SARA 313)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:N-BUTYL ACETATE (VAPOR PRESSURE 10.00 MM HG @ 20 C) (LEL
1.38 @ 38 C)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 1-5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM
ACGIH TLV:150 PPM;200 PPM STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL ACETATE (VAPOR PRESSURE 100.00 MM HG @ 27 C) (LEL
2.18 @ 25 C)
CAS:141-78-6
RTECS #:AH5425000
Fraction by Wt: 5-10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 1-5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL ETHYL KETONE (SARA 313) (VAPOR PRESSURE 70.20 MM HG
@ 20 C) (LEL 1.80 @ 25 C)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 5-10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM
ACGIH TLV:200 PPM;300 PPM STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TALC
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 15-20%
Other REC Limits:NONE SPECIFIED
OSHA PEL:20 MPPCF
ACGIH TLV:2 MG/M3 (RESP DUST)
Ingred Name:SANDING OR GRINDING DRIED FILM OF PRODUCT PRODUCES NUISANCE
DUST.
RTECS #:9999999ZZ
Other REC Limits:*5MG/M3 RESP DUST
OSHA PEL:15MG/M3 TOTAL DUST*
ACGIH TLV:10MG/M3 TOTAL DUST
Ingred Name:SKIN: ABSORBTION MAY CONTRIBUTE TO OVERALL EXPOSURE TO THIS
MATERIAL. TAKE APPROPRIATE MEASURES TO PREVENT SKIN CONTACT.
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:EYE: MODERATE IRRITATE/CORNEAL DAMAGE.
SKIN: MODERATE IRRITATE/DAMAGE/DEFAT/DRY/DERMATITIS/TEMP OR PERM
SKIN SENSITIZATION ABSORP: SYMPTS SAME AS INHALE/INGEST. INHALE:
IRRIT/NOSE/THROAT/RSPRTRY TRACT /MUCOUS MEMBRANE/CENT NERV SYST
DEPRES/PERM BRAIN DAMAGE/NERV SYST DAMAGE. INGEST: SEVERELY
TOXIC/ASPIRATION IN LUNGS**
Explanation of Carcinogenicity:N/K **CHROMATES ARE LISTED AS
CARCINOGENS.
Effects of Overexposure:EYE: IRRITATE/PAIN/TEAR/RED/SWELL. SKIN:
IRRITATE/RED/SWELL/RASH. RSPRTRY: IRRITATE/RUNNY NOSE/SORE
THROAT/COUGH/CHEST DISCOMFORT/SHORT BREATH/REDUCED LUNG FUNCTION.
GASTROINTESTINAL: IRRITATE/SORE TH ROAT/ABDOMINAL
PAIN/NAUSEA/VOMIT/DIARRHEA. CENT NERV SYST DEPRES:
HEADACHE/DIZZY/NAUSEA/SYMPS OF INTOX/UNCONSCIOUS/***
Medical Cond Aggravated by Exposure:PREEXISTING EYE/SKIN/RSPRTRY
DISORDERS/IMPAIRED REPRODUCTIVE FUNCTION.***DEATH. CHRONIC
OVEREXPOSURE: LOSS OF MEMORY/INTELLECTUAL ABILITY/COORDINATION.
LEAD POISON: LOSS OF APPETITE/METALLIC TASTE****
======================= First Aid Measures =======================
First Aid:EYE: IMMED FLUSH W/WTR 15 MIN HOLD LIDS OPEN. IMMED MED AID.
SKIN: REMOVE CONTAM CLOTH. WIPE EXCESS OFF/FLUSH W/SOAP/WTR. MED
AID--IRRITATE OCCURS. INHALE: GROSS OVEREXPOSURE TO NUISANCE
DUST-IRRITATE RSPRTRY TRACT. INGEST: NO VOMIT. IF VOMIT OCCURS
KEEP HEAD BELOW HIPS-PREVENT ASPIRATION INTO LUNGS/SERIOUS DAMAGE.
DR DECIDES TO INDUCE VOMIT. PHYSICIAN/HOSPITAL/POISON CNTR/TRANS TO
EMERG CNTR
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:20.0F,-6.7C
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:WARNING: FLAMMABLE. NO UNPROTECTED PERSONS.
PRESSURE SCBA IN CONFINED FIRE SPACE.
Unusual Fire/Explosion Hazard:COOL CONTAINERS EXPOSED TO INTENSE HEAT
W/WATER TO PREVENT VAPOR PRESSURE BUILDUP/CONTAINER RUPTURE. COOL
CONTAINER AREAS EXPOSED TO DIRECT FLAME CONTACT W/WTR*
================== Accidental Release Measures ==================
Spill Release Procedures:LRG: NO UNPROTEC PEOPLE. APPROP RSPRTR/PROTEC
CLOTH. STOP LEAK IF SAFE. DIKE/CONTAIN. USE WTR FOG TO SUPPRESS
VAPOR CLOUD. CONTAIN RUN-OFF. RMV W/VACUUM TRUCKS/PUMP--STORAGE
VESSEL. SOAK UP RESIDUE W/ ABSORB MAT'L. PUT IN NON-LEAK
CNTNR-FORDISPOSAL*
Neutralizing Agent:N/K *FLUSH/REMOVE W/WTR. SMALL: TAKE UP W/ABSORB
MAT'L/PUT IN NON-LEAK CNTNR.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID HEAT/SPARKS/FLAME. NO PILOT
LIGHTS/CIGARETTES/INGNITION SOURCES BEFORE/AFTER USE TIL VAPORS
GONE. CNTNRS CLSD WHEN NOT IN USE.
Other Precautions:HOT SURFACES MAY IGNITE PRODUCT. VAPORS MAY TRAVEL TO
IGNITE SOURCE. CONTAINERS, EVEN EMPTY, CAN CONTAINE EXPLOSIVE
VAPORS. DO NOT CUT/DRILL/GRIND/WELD NEAR EMPTY CONTAINERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE VENTILATION TO CONTROL VAPOR
CONCENTRATIONS-AT LEAST 10 AIR CHANGES PER HOUR RECOMMENDED. IF
EXPOSURE EXCEEDS PEL/TLV, USE APPROPRIATE NIOSH-APPROVED RESPIRATOR
Ventilation:USE ADEQUATE VENTILATION.
Other Protective Equipment:NO CONTACT LENSES. PROTECTIVE CLOTHING TO
PREVENT SKIN CONTACT. EYE WASH FOUNTAIN/SAFETY SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:DO NOT REUSE CLOTHING UNTIL THOROUGHLY
DECONTAMINATED. WASH W/SOAP/WATER BEFORE
EATING/DRINKING/SMOKING/USING TOILET.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Density:>1 (AIR=1)
Spec Gravity:11.06 LB/GL
Evaporation Rate & Reference:<1 (ETHER=1)
Percent Volatiles by Volume:48.36
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS, STRONG ACIDS. UNDER UNCONTROLLED CONDITIONS:
AMINES, POLYAMINES, POLYAMIDES. BROMINE PENTAFLUORIDE.
Stability Condition to Avoid:N/K *TO PREVENT WEAKENING OF CONTAINER
STRUCTURE.
Hazardous Decomposition Products:ALDEHYDES, ACIDS, CARBON DIOXIDE,
CARBON MONOXIDE, AND UNIDENTIFIED ORGANIC COMPOUNDS FORMED DURING
COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:OBSERVE LOCAL, STATE AND FEDERAL
REGULATIONS.****ANXIETY/CONSTIPATION/NAUSEA/PALLOR/EXCESSIVE
TIRED/WEAK/INSOMNIA/HEADACHE/NERV IRRITABILITY/MUSCLE-JOINT
PAIN/FINE TREMORS/NUMBNESS/DIZZY/HYPERACTIVITY /COLIC.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:470/473/1020/1030 INDUSTRIAL ENAMELS-METALLIC TOPCOATS
CAGE:08882
CAGE:08882
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 50-55%
Other REC Limits:525 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 0-2%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: HARMFUL IF INHALED. MAY
AFFECT THE BRAIN/NERVOUS SYSTEM. CAUSES NOSE & THROAT IRRITATION.
SKIN/EYE CONTACT: CAUSES IRRITATION & MAY LEAD TO DERMATITIS
W/REPEATED OVEREXPOSURES. INGESTION: ASPIRATION OF THIS MATERIAL
INTO LUNGS CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL. GI
IRRITATION. SEE SUPP.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:DIZZINESS, HEADACHE, NAUSEA, STAGGERING GAIT,
CONFUSION, UNCONSCIOUSNESS, COMA, IRRITATION, DIARRHEA & VOMITING.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR, RESTORE BREATHING. EYES:
FLUSH W/PLENTY OF WATER FOR 15 MINS. SKIN: WASH AREA W/PLENTY OF
WATER FOR 15 MINS. INGESTION: DON'T INDUCE VOMITING. KEEP PERSON
WARM, QUIET. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:104F
Lower Limits:SEE SUPP
Extinguishing Media:C02, DRY CHEMICAL/FOAM.
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIPMENT & SCBA. WATER
SPRAY MAY BE INEFFECTIVE. WATER MAY BE USED TO COOL CLOSED
CONTAINERS. IF WATER IS USED, FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS, & OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSE TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION, VENTILATE AREA
& REMOVE W/INERT ABSORBENT & NONSPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE >120F. LARGE QUANTITIES
PROTECTED FOR STORAGE OF NFPA CLASS II COMBUSTIBLE LIQUIDS.
CONTAINERS SHOULD BE GROUNDED WHEN POURING.
Other Precautions:DON'T INCINERATE CLOSED CONTAINERS. DON'T TAKE
INTERNALLY. EMPTY CONTAINERS MAY BE HAZARDOUS. DON'T APPLY TO HOT
SURFACES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED CHEMICAL CARTRIDGE RESPIRATOR
TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY & ORGANIC VAPORS
DURING SPRAY APPLICATION. CONFINED AREAS: USE NIOSH APPROVED
SUPPLIED-AIR RESPIRATORS/ HOODS.
Ventilation:GENERAL DILUTION/LOCAL EXHAUST IN VOLUME & PATTERN.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
LOWER EXPLOSIVE LIMIT: 0.9 FOR MINERAL SPIRITS & 1 FOR XYLD. HAZ ACUTE
CONT'D: CHRONIC: REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS CAN
CAUSE PERMANENT BRAIN/NERVOUS SYSTEM DAMAGE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:281-389F
Vapor Density:>1
Evaporation Rate & Reference:(ETHER=1): SLOWER
Percent Volatiles by Volume:64-68
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, ELECTRICAL EQUIPMENT, SPARKS, & OPEN
FLAME.
Hazardous Decomposition Products:CO & CO2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SODIUM NITRATE, SODNIF
CAGE:6N767
CAGE:6N767
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM NITRATE
CAS:7631-99-4
RTECS #:WC5600000
Fraction by Wt: 99%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRITATION OF SKIN AND/OR
MUCOUS MEMBRANES. INGESTION OF LARGE AMOUNTS CAUSES
GASTROENTERITIS. SYMPTOMS OF EXPOSURE: DIZZINESS, ABDOMINAL CRAMPS,
VOMITING, HEADACHE, MENTAL IMPAIRMENT, CYANOSIS . CHRONIC: ANEMIA,
METHEMOGLOBINEMIA, NEPHRITIS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:DERMATITIS, ALLERGIES AND
RESPIRATORY DISORDERS SUCH AS EMPHYSEMA OR ASTHMA.
======================= First Aid Measures =======================
First Aid:SKIN: FLUSH THOROUGHLY WITH WATER. EYES: FLUSH WITH WATER FOR
AT LEAST 15 MINUTES. CALL MD. INGESTION: DRINK WATER. INDUCE
VOMITING BY STICKING FINGER DOWN THROAT. CALL MD. INHALATION:
REMOVE TO FRESH AIR. CALL MD.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, WATER SPRAY, FOAM OR
FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . REMOVE CONTAINERS FROM FIRE IF POSSIBLE W/OUT RISK.
COOL CONTAINERS EXPOSED TO FLAMES W/WATER.
Unusual Fire/Explosion Hazard:OXIDIZER. KEEP AWAY FROM REDUCING AGENTS.
WILL EXPLODE IF HEATED TO 1,000C IN PRESENCE OF REDUCING AGENTS,
ORG MATLS OR MIXED W/CYANIDES. YIELDS TOX (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN, SWEEP OR VACUUM UP TAKING CARE NOT TO
SPREAD OR RAISE DUST.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY AREA AWAY FROM
OTHER REDUCING AGENTS & LIQUIDS OF LOW FLASH POINTS. STORAGE AREA
SHOULD BE WELL VENTILATED & FIRE PROOF.
Other Precautions:AVOID CONTACT WITH SKIN, EYES & CLOTHING. AVOID
BREATHING DUST OR MIST. USE NORMAL PERSONAL HYGIENE & HOUSEKEEPING.
REMOVE ALL EMPTY OR USED CONTAINERS FROM PREMISES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:VENTILATE AS NECESSARY TO ELIMINATE DUST FROM WORK AREA.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER . USE
CLOTHING SUFFICIENT TO PROTECT SKIN FROM DUST.
Work Hygienic Practices:AS REQD TO PROTECT SKIN & EYES FROM DUST. DO
NOT LEAVE FOOD OR SMOKE IN WORK AREA. WASH THORO & REMOVE/CLEAN
(SUPDAT)
Supplemental Safety and Health
BP: DECOMPOSES AT 716F,380C. EXPLO HAZ: GASEOUS OXIDES WHEN HEATED.
HYGIENE PRACT: ANY CONTAMD CLOTHING.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:SUPDAT
Melt/Freeze Pt:M.P/F.P Text:585F,307C
Decomp Temp:Decomp Text:716F,380C
Spec Gravity:2.26 (H*2O=1)
Solubility in Water:SOLUBLE
Appearance and Odor:WHITE GRANULES OR PELLETS; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:REDUCING AGENTS AND FLAMMABLE OR
COMBUSTIBLE MATERIALS.
Hazardous Decomposition Products:OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE
AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: SULFAMIC ACID REAGENT
Cage: 4T252
Box: 907
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 4T252
Box: 907
=======================================================
Contractor Summary
=======================================================
Cage: 91224
Box: 389
Cage: 4T252
Box: 907
=======================================================
Ingredients
=======================================================
Cas: 5329-14-6
RTECS #: WO5950000
------------------------------
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: CORROSIVE TO EYES, WET SKIN, & RESPIRATORY TRACT.
CAUSES BURNS.
Explanation Of Carcinogenicity: NONE
Medical Cond Aggravated By Exposure: PRE-EXISTING SKIN DISORDERS
First Aid: EYES/SKIN: FLUSH W/WATER FOR 15 MIN. INGESTION: DON'T INDUCE
VOMITING. GIVE 1 TO 2 GLASSES OF WATER. CALL PHYSICIAN IMMEDIATELY. NEVER
GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. INHALATION: REMO VE TO FRESH
AIR. GIVE ARTIFICIAL RESPIRATION IF NECESSARY. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: COVER CONTAMINATED SURFACES W/NEUTRALIZER. MIX &
ADD WATER IF NECESSARY. USE LITMUS PAPER TO MAKE SURE PH OF SLURRY IS NEUTRAL
OR ADD NEUTRALIZER UNTIL MIXTURE STOPS BUBBLING. SCOOP UP SLURRY & WASH D
OWN THE NEUTRAL WASTE DOWN THE DRAIN W/WATER.
Neutralizing Agent: SODA ASH OR SODIUM BICARBONATE.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, & FEDERAL
REGULATIONS. CORROSIVE. UN1759.
Handling And Storage Precautions: STORE TIGHTLY CLOSED IN A DRY PLACE. AVOID
CONTACT W/SKIN, EYES, CLOTHING. DON'T BREATHE DUST. KEEP AWAY FROM HEAT,
SPARKS, & OPEN FLAME.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: WATER OR DRY CHEMICAL
Unusual Fire/Explosion Hazard: MAY REACT VIOLENTLY W/CHLORINE OR FUMING NITRIC
ACID; MAY EMIT TOXIC FUMES IN FIRE.
=======================================================
Control Measures
=======================================================
Ventilation: ADEQUATE
Other Protective Equipment: LAB COAT
Work Hygienic Practices: REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
=======================================================
Physical/Chemical Properties
=======================================================
M.P/F.P Text: 205C
Spec Gravity: 2.09
PH: 0.6
Solubility in Water: COMPLETE
Appearance and Odor: SOLID; WHITE CRYSTALLINE POWDER; ODORLESS.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: MOISTURE, HEAT, FLAMES.
Materials To Avoid: CHLORINE OR FUMING NITRIC ACID
Hazardous Decomposition Products: SULFUR OXIDES OR NITROGEN OXIDES
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: SULFAMIC ACID REAGENT
Cage: 4T252
Company Name: HACH COMPANY
Street: 100 DAYTON RD.
PO Box: 907
Zipcode: 50010
Label Required IND: Y
Date Of Label Review: 09/13/1993
Status Code: C
Label Date: 09/13/1993
Origination Code: F
Skin Protection IND: YES
Signal Word: DANGER
Health Hazard: Moderate
Contact Hazard: Severe
Fire Hazard: None
Reactivity Hazard: Slight
Hazard And Precautions: CORROSIVE TO EYES, WET SKIN, & RESPIRATORY TRACT.
CAUSES BURNS.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CYCLOHEXYLAMINE
Preparer's Name:DOUGLAS EISNER
CAGE:DO735
CAGE:DO735
CAGE:0AN91
============= Composition/Information on Ingredients =============
Ingred Name:CYCLOHEXYLAMINE (SARA III)
CAS:108-91-8
RTECS #:GX0700000
Fraction by Wt: >99%
OSHA PEL:10 PPM
ACGIH TLV:10 PPM; 9192
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL: RAT LD50 = 11 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: IRRITATION TO
RESPIRATORY TRACT. MAY CAUSE SENSITIZATION. EYE: VAPORS, LIQUID &
MISTS ARE EXTREMELY CORROSIVE, CAUSING SEVERE DAMAGE TO EYES. LARGE
QUANTITIES CAN CAUSE DEATH. CHRON IC: IRRITANT DERMATITIS.
Explanation of Carcinogenicity:NOT CONSIDERED A CARCINOGEN BY THE
NATIONAL TOXICOLOGY PROGRAM, THE INTERNATIONAL AGENCY FOR RESEARCH
ON CANCER OR OSHA.
Effects of Overexposure:INHALATION: IRITATION, LIGHT-HEADEDNESS,
DROWSINESS, ANXIETY, NAUSEA AND VOMITING. EYE: SEVERE IRRITATION.
SKIN: SEVERE IRRITATION. INGESTION:TISSUE BURNS AND S
Medical Cond Aggravated by Exposure:NONE REPORTED.
======================= First Aid Measures =======================
First Aid:INHALED: REMOVE TO FRESH AIR. GIVE CPR IF NOT BREATHING. GET
IMMEDIATE MEDICAL ATTENTION. EYE: IMMEDIATELY FLUSH EYES WITH LOTS
OF WATER FOR 15 MINUTES. GET IMMEDIATE MEDICAL ATTENTION. SKIN:
FLUSH SK TED CLOTHING & SHOES. GET IMMEDIATE MEDICAL ATTENTION.
INGESTION: DO NOT INDUCE VOMITING. GIVE WATER TO DRINK IF
CONSCIOUS. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:89.0F,31.7C
Autoignition Temp:Autoignition Temp Text:560F
Lower Limits:1.6
Upper Limits:9.4
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL; DO NOT USE
WATER TO FIGHT FIRE.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:WATER MAY CAUSE THIS PRODUCT WILL FLOAT
AND MAY REIGNITE ON THE SURFACE OF THE WATER. VAPORS ARE HEAVIER
THAN AIR AND MAY TRAVEL TO OTHER IGNITION SOURCES.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT INCLUDING RUBBER
APPARATUS. EXTINGUISH ALL IGNITION SOURCES. CONTAIN BY DIKING WITH
SOIL. PUMP, ABSORB, MO P OR WIPE UP FOR DISPOSAL. KEEP OUT OF
SEWERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS, AND
FLAMES. STORE IN A COOL, DRY, WELL-VENTILATED PLACE AWAY FROM
INCOMPATABLE MATERIALS. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:VENT CONTAINER FREQUENTLY, AND MORE OFTEN IN WARM
WEATHER TO RELIEVE PRESSURE. ELECTRICALLY GROUND ALL EQUIPMENT WHEN
HANKLING PRODUCT AND USE ONLY NON-SPARKING TOOLS. DO NOT USE
PRESSURE TO EMPTY CON TAINER. DO NOT CUT, GRIND, WELD IN AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH-APPROVED RESPIRATOR APPROPRIATE FOR
EMISSION LEVELS. APPROPRIATE RESPIRATORS MAY BE A FULL FACEPIECE
AIR-PURIFYING CARTRIDGE EQUIPPED FOR ORGANIC VAPORS/MISTS, A SCBA
IN THE PRESSURE DEMA ND MODE, OR A SUPPLIED-AIR RESPIRATOR.
Ventilation:LOCAL MECHANICAL EXHAUST VENTILATION CAPABLE OF MAINTAINING
EMISSIONS AT THE POINT OF USE BELOW THE TLV.
Other Protective Equipment:LONG-SLEEVED SHIRT, TROUSERS, RUBBER BOOTS,
RUBBER APRON, EYE WASH STATION & SAFETY SHOWER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. DO NOT GET IN
EYES, ON SKIN OR ON CLOTHING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
"EMPTY" CONTAINERS WILL RETAIN PRODUCT RESIDUE AND VAPORS. ALWAYS OBEY
HAZARD WARNINGS AND HANDLE EMPTY CONTAINERS AS IF THEY WERE FULL.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:273.0F
Melt/Freeze Pt:M.P/F.P Text:0.0F,-17.8C
Vapor Pres:10-14
Vapor Density:3.42
Spec Gravity:0.86
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID, STRONG FISHY ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, STRONG OXIDIZING AGENTS, ALL COPPER ALLOYS, LEAD.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, OPEN FLAMES
Hazardous Decomposition Products:MAY LIBERATE CORBON MONOXIDE, CARBON
DIOXIDE, AND OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF CONTAMINATED PRODUCT AND MATERIALS
USED IN CLEANING UP SPILLS OR LEAKS IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE, AND LOCAL REGULATIONS. NOTE: EMPTY
CONTAINERS CAN HAVE RESIDUES SUBJ ECT TO PROPER WASTE DISPOSAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FOTO PLATE 8 DEVELOPER DESENSITIZER
CAGE:FO598
CAGE:09177
CAGE:FO598
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS FOR INGREDIENTS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: MILD IRRITATION. INGESTION:
STOMACH OR GASTRO-INTESTINAL IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN/EYES: MILD IRRITATION. INGESTION: STOMACH
OR GASTRO-INTESTINAL IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER. SKIN: WASH W/SOAP & WATER. INGESTION:
INDUCE VOMITING. GET MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NON-FLAMMABLE, WATER SOLUTION
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:WASH W/WATER OR USE ABSORBENT MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID FREEZING. STORE40 & 140F.
DON'T REUSE CONTAINER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED
Ventilation:NOT REQUIRED
Other Protective Equipment:APRON
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Spec Gravity:1.015
pH:4.0
Evaporation Rate & Reference:(BU AC = 1): <WATER
Solubility in Water:COMPLETE
Appearance and Odor:PALE WHITE LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:FREEZING
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:NON-HAZARDOUS, REFER TO LOCAL REGULATIONS FOR
LIQUID DISPOSAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:METHANOL
Preparer's Name:JOHN TAHBAZ
CAGE:67281
CAGE:67281
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 100% %
Other REC Limits:NONE SPECIFIED
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: CAN CAUSE SEVERE IRRITATION.
SKIN: PROLONGED CONTACT CAN CAUSE REDDENING AND DEFATTING OF THE
SKIN. INHALATION: MAY CAUSE DIZZINESS, DROWSINESS, DISTURBANCES OF
VISION, NUMBNESS. INGESTION: MODE RATE QUANTITIES CAN PRODUCE
METABOLIC ACIDOSIS. ONSET OF SYMPTOMS MAY BE DELAYED UP TO 48
HOURS. 60-200 ML IS FATAL DOSE
Explanation of Carcinogenicity:NONE SPECIFIED BY MANUFACTURER.
Effects of Overexposure:EYES: REDNESS, TEARING, BLURRED VISION. SKIN:
DEFATTING, DERMATITIS. INHALATION: NASAL IRRITATION, DIZZINESS,
WEAKNESS, FATIGUE, NAUSEA, VOMITING, DIARRHEA, UNCONSCIOUSNESS,
DEATH. INGESTION: NAUSEA, VOMITING, DIARRHEA, BLINDNESS, DEATH.
Medical Cond Aggravated by Exposure:EXISTING SKIN CONDITION, LIVER
AND/OR KIDNEY DISEASES.
======================= First Aid Measures =======================
First Aid:IF ON SKIN: THOROUGHLY WASH EXPOSED AREA WITH SOAP AND WATER.
REMOVE CONTAMINATED CLOTHING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. IF IN EYES: FLUSH WITH LARGE AMOUNTS OF WATER, LIFTING UPPER
AND LOWER LIDS. GET MEDICAL ATTENTION. IF SWALLOWED: IMMEDIATELY
DRINK 2 GLASSES OF WATER AND INDUCE VOMITING. NEVER GIVE ANYTHING
BY MOUTH TO AN UNCONSCIOUS PERSON. INHALATION: REMOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:=12.2C, 54.F
Lower Limits:5.5
Upper Limits:36.5
Extinguishing Media:ALCOHOL-TYPE OR ALL-PURPOSE FOAMS BY MANUFACTURER'S
RECOMMENDED TECHNIQUES FOR LARGE FIRE. CARBON DIOXIDE FOR SMALL
FIRE
Fire Fighting Procedures:USE WATER SPRAY TO COOL FIRE-EXPOSED
CONTAINERS. APPROACH METHANOL FIRE WITH CAUTION. USE SELF-CONTAINED
BREATHING APPARATUS AND PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND MAY
TRAVEL ALONG THE GROUND OR MAY BE MOVED BY VENTILATION AND IGNITED
BY PILOT LIGHTS, OTHER FLAMES, SPARKS, HEATERS, ETC.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILL: ELIMINATE ALL SOURCES OF IGNITION
SUCH AS FLARES, FLAMES AND ELECTRICAL SPARKS. ABSORB LIQUID ON
PAPER, VERMICULITE, FLOOR ABSORBENT, OR OTHER ABSORBENT MATERIAL.
DO NOT TURN ON ANY IGNIT ION SOURCES UNTIL AREA IS FREE FROM
FIREHAZARDS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM SPARKS, OPEN FLAMES.
NEVER USE WELDING OR CUTTING TORCH ON OR NEAR DRUM BECAUSE PRODUCT
CAN IGNITE EXPLOSIVELY.
Other Precautions:CONTAINERS SHOULD BE GROUNDED AND/OR BONDED WHEN
MATERIAL IS TRANSFERRED. CONTAINERS OF THIS MATERIAL MAY BE
HAZARDOUS WHEN EMPTIED, SINCE EMPTIED CONTAINERS RETAIN PRODUCT
RESIDUES. ALL PRECAUTIONS G IVEN IN THE DATA SHEET APPLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELF-CONTAINED BREATHING APPARATUS IN HIGH VAPOR
CONCENTRATIONS.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment:CHEMICAL APRON, EYE BATH AND SAFETY SHOWER
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER EACH USE.
Supplemental Safety and Health
DANGER! POISON! MAY BE FATAL OR CAUSE BLINDNESS IF SWALLOWED. CANNOT BE
MADE NONPOISONOUS. VAPOR HARMFUL.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:=63.9C, 147.F
Vapor Pres:96 @ 20C
Vapor Density:1.1
Spec Gravity:.7925
Evaporation Rate & Reference:5.8 (BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR COLORLESS MOBILE LIQUID WITH MILD ALCOHOL
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALI METALS, CONCENTRATED NITRIC AND SULFURIC ACIDS, ALDEHYDES, ACYL
CHLORIDES.
Stability Condition to Avoid:IGNITION SOURCES
Hazardous Decomposition Products:CARBON DIOXIDE AND CARBON MONOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN A FURNACE WHERE PERMITTED UNDER
APPROPRIATE FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:KIRK'S COCO HARDWATER CASTILE SOAP
CAGE:DO549
CAGE:DO549
CAGE:74188
============= Composition/Information on Ingredients =============
Ingred Name:FRAGRANCE
Ingred Name:SOAP
Ingred Name:COCONUT OIL
Ingred Name:GLYCERIN
CAS:56-81-5
RTECS #:MA8050000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 (MIST) 9293
Ingred Name:FATTY ESTERS
Ingred Name:COCONUT ACIDS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: MILD IRRITANT. INGESTION: MILD
GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING OR DIARRHEA. SKIN:
IRRITATE, DRY.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYE: MILD IRRITANT. INGESTION: MILD
GASTRTOINTESTINAL IRRITATION, NAUSEA, VOMITING OR DIARRHEA. SKIN:
IRRITATE OR DRY.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH THOROUGHLY W/WATER. INGESTION: DILUTE W/FLUIDS &
TREAT SYMPTOMATICALLY. SKIN: DISCONTINUE USE.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, WATER OR DRY CHEMICAL
Fire Fighting Procedures:NONE REQUIRED
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP & PLACE IN WASTE CONTAINER. FLUSH
SPILL AREA W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID STRONG WHERE MOISTURE CONTACTS
CASE OR PRODUCT WRAPPER.
Other Precautions:NONE REQUIRED
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Ventilation:MECHANICAL: ACCEPTABLE
Other Protective Equipment:NONE REQUIRED
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:1.25
Solubility in Water:MODERATE
Appearance and Odor:CREAM WHITE BAR W/LIGHT PERFUME.
Percent Volatiles by Volume:20%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL IN ACCORDANCE W/LOCAL, STATE, & FEDERAL
REGULATIONS. DISPOSE AS DRY SCRAP OR FLUSH DOWN SEWER W/LARGE
EXCESS OF WATER.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:LIGHTWEIGHT BODY FILLER, DX4
CAGE:47695
CAGE:47695
============= Composition/Information on Ingredients =============
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (MAGNESIUM
SILICATE)
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 30-35%
OSHA PEL:2 MG/M3 RESP
ACGIH TLV:2 MG/M3 RESP
Ingred Name:STYRENE (SARA III)
CAS:100-42-5
RTECS #:WL3675000
Fraction by Wt: 15-20%
OSHA PEL:100 PPM
ACGIH TLV:S,50PPM/100STEL;9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:FILM FORMERS, RESINS AND ADDITIVES
Fraction by Wt: 50-55%
OSHA PEL:NOT APPLICABLE.
ACGIH TLV:NOT APPLICABLE.
Ingred Name:FIRST AID PROC:THE PRESENCE OF UV LIGHT MAY ENHANCE
SENSITIVITY OF SKIN/EYES. IF ANY OF THE FOLLOWING OCCUR (ING 5)
RTECS #:9999999ZZ
OSHA PEL:NOT APPLICABLE.
ACGIH TLV:NOT APPLICABLE.
Ingred Name:ING 4:DURING/FOLLOWING USE OF THIS PROD, CONT A POIS CTL
CTR, EMER ROOM OR MD IMMED; HAVE MSDS INFO AVAIL. (ING 6)
RTECS #:9999999ZZ
OSHA PEL:NOT APPLICABLE.
ACGIH TLV:NOT APPLICABLE.
Ingred Name:ING 5:*INGESTION *EXCESSIVE EXPOSURE TO A CORROSIVE
MATERIAL *PERSISTENT SKIN/EYE IRRITATION OR BREATHING DIFFICULTIES.
RTECS #:9999999ZZ
OSHA PEL:NOT APPLICABLE.
ACGIH TLV:NOT APPLICABLE.
Ingred Name:RESP PROT:AIRBORNE CONTAMINANTS AGAINST WHICH THE
RESPIRATOR IS EFFECTIVE & HOW IT IS TO BE PROPERLY FITTED.
RTECS #:9999999ZZ
OSHA PEL:NOT APPLICABLE.
ACGIH TLV:NOT APPLICABLE.
Ingred Name:VENT:LOWEST SUGGESTED EXPOS LIMITS, THE LEL BELOW STATED
LIMIT & TO REMOVE DECOMP PRODS DURING WELDING/FLAME (ING 9)
RTECS #:9999999ZZ
OSHA PEL:NOT APPLICABLE.
ACGIH TLV:NOT APPLICABLE.
Ingred Name:ING 8:CUTTING ON SURFACES COATED W/THIS PRODUCT.
RTECS #:9999999ZZ
OSHA PEL:NOT APPLICABLE.
ACGIH TLV:NOT APPLICABLE.
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INGEST:HARMFUL IF SWALLOWED.
EYE:CAUSES IRRIT. SKIN:MAY CAUSE MOD IRRIT. INHAL:VAP/SPRAY MIST
MAY BE HARMFUL. IRRITATES EYES, NOSE & THROAT. RPTD EXPOS TO HIGH
VAP CONC MAY CAUSE IRRIT OF RESP SYS & PERM BRAIN & NERV SYS DAM.
INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING & (EFTS OF
OVEREXP)
Explanation of Carcinogenicity:STYRENE: GROUP 2B (IARC)
Effects of Overexposure:HTLH HAZ:INHALING CONTENTS CAN BE
HARMFUL/FATAL. CHRONIC:AVOID LONG TERM/RPTD CONT. SIGN/SYMPS:EYE
WATERING, HDCH, NAUS, DIZZ & LOSS OF COORD ARE INDICATIONS THAT
SOLV LEVELS ARE TOO HIGH. REDNESS, IT CHING, BURNING SENSATION &
VISUAL DISTURB MAY INDICATE EXCESSIVE EYE CONT. DRYNESS, ITCHING,
CRACKING, (SUPP DATA)
Medical Cond Aggravated by Exposure:NOT APPLICABLE.
======================= First Aid Measures =======================
First Aid:INGEST:IF SWALLOWED, DO NOT INDUCE VOM. EYE:FLUSH IMMED
W/PLENTY OF WATER FOR AT LEAST 15 MINS. SKIN:FLUSH IMMED W/PLENTY
OF WATER FOLLOWED BY WASHING W/SOAP & WATER. INHAL:IF AFFECTED BY
INHAL OF VAP /SPRAY MIST, REMOVE TO FRESH AIR. APPLYARTF RESP &
OTHER SUPPORTIVE MEASURES AS REQD. OTHER:IN CASE OF ACCIDENTAL
SKIN/EYE CONT, AVOID CONCURRENT EXPOS TO SUN/OTHER SOURCES OF UV
LIGHT. (ING 4)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:88.0F,31.1C
Lower Limits:1.1
Extinguishing Media:NFPA CLASS B EXTING (CO*2, DRY CHEM OR UNIVERSAL AQ
FILM FORMING FOAM) DESIGNED TO EXTING NFPA CLASS IC FLAM LIQ FIRES.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER SPRAY MAY BE INEFT, BUT MAY BE USED TO COOL CLSD CONTRS TO
PVNT PRESS BUILD-UP & POSS (SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPARKS & OPEN FLAMES. CLSD CONTRS MAY EXPLODE
WHEN EXPOSED TO EXTREME HEAT. DO NOT APPLY ON (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:PROVIDE MAX VENT. ONLY PERS EQUIPPED W/PROPER
NIOSH/MSHA APPRVD RESP & SKIN/EYE PROT SHOULD BE PERMITTED IN AREA.
REMOVE ALL SOURCES OF IGNIT. TAKE UP SPILLED MATL W/SAWDUST,
VERMICULITE OR OTHER ABSO RB MATL & PLACE INTO CONTAINERS FOR
DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 90F. STORE LGE QTYS
IN BLDGS DESIGNED & PROTECTED FOR STOR OF NFPA CLASS IC FLAMM
LIQUIDS. CONTRS SHOULD BE GROUNDED WHEN POURING.
Other Precautions:AVOID FREE FALL OF LIQ IN EXCESS OF A FEW INCHES. IF
THIS MATL IS PART OF A MULTIPLE COMPONENT COATING SYSTEM, READ THE
MSDS FOR OTHER COMPONENT/COMPONENTS BEFORE BLENDING AS RESULTING
MIX MAY HAVE TH E HAZARDS OF ALL OF ITS PARTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:OVEREXPOS TO VAPS MAY BE PVNTD BY ENSURING VENT,
CONTROLS, VAP EXHST OR FRESH AIR ENTRY. NIOSH/MSHA APPRVD (TC-23C)
ORG VAP RESPS MAY ALSO REDUCE EXPOS. READ RESP MFRS INSTRUCTIONS &
LITERATURE CAREFU LLY TO DETERM TYPE OF (ING 7)
Ventilation:PROVIDE GEN DILUTION OR LOC EXHST VENT IN VOL & PATERN TO
KEEP CONC OF INGREDS LISTED IN INGRED SECT BELOW (ING 8)
Other Protective Equipment:WEAR PROTECTIVE CLOTHING, INCLUDING
IMPERMEABLE APRON CONSTRUCTED OF POLYETHYLENE, BUTYL RUBBER OR
NITRILE RUBBER.
Work Hygienic Practices:CLEAN OR DISCARD CONTAMINATED CLOTHING & SHOES.
Supplemental Safety and Health
FIRE FIGHT PROC:AUTOIGNIT/EXPLOS WHEN EXPOSED TO EXTREME HEAT. IF WATER
IS USED, FOG NOZZ ARE PREFERABLE. EXPLO HAZ:HOT SURF. TOX GASES MAY
FORM WHEN PROD IS CONTACTED BY FLAME/HOT SURF. HAZ DECOMP PR
OD:PRDCE FUMES INCL:CARBON MONOXIDE. EFTS OF OVEREXP:BURNING,
REDNESS & SWELLING CNDTNS ASSOC W/EXCESSIVE SKIN CONT.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:>295F,>146C
Vapor Pres:0.5
Vapor Density:HVR/AIR
Spec Gravity:1.42
Evaporation Rate & Reference:49 (BUTYL ACETATE=1)
Solubility in Water:O.O%
Appearance and Odor:VISCOUS LIQ W/A DISTINCTIVE ODOR THAT IS
CHARACTERISTIC OF UV/EB CURABLE MATLS.
Percent Volatiles by Volume:23.40
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
FREE RADICAL INITIATORS, PEROXIDES, STRONG ALKALIES OR REACTIVE METALS
COULD CAUSE MATLS TO POLYMERIZE EXOTHERMICALLY.
Stability Condition to Avoid:EXPOSURE TO HIGH TEMPS (>90F) & STRONG UV
LIGHT SOURCES. SEE ALSO MATERIALS TO AVOID.
Hazardous Decomposition Products:MAY PRDCE HAZ DECOMP PRODS WHEN
HEATED, WELDING, BRAZING OR FLAME CUTTING ON SURF COATED W/THIS
PROD MAY (SUPP DATA)
Conditions to Avoid Polymerization:EXPOSURE TO HIGH TEMPERATURE (>90F)
& STRONG UV LIGHT SOURCES. ALSO SEE MATERIALS TO AVOID.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MATERIAL MUST BE DISPOSED OF IN ACCORDANCE
W/FEDERAL, STATE, PROVINCIAL & LOCAL ENVIRONMENTAL CONTROL
REGULATIONS. EMPTY CONTAINERS SHOULD BE RECYCLED OR DISPOSED OF
THOROUGH AN APPROVED WASTE M ANAGEMENT FACILITY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:WELD-ON 2705 LOW VOC PLASTIC PIPE CEMENT
Preparer's Name:HENRY SIMMONS
CAGE:17510
CAGE:17510
============= Composition/Information on Ingredients =============
Ingred Name:POLYVINYL CHLORIDE RESIN
Ingred Name:TETRAHYDROFURAN
CAS:109-99-9
RTECS #:LU5950000
OSHA PEL:590 MG/M3;200 PPM
ACGIH TLV:590 MG/M3;200 PPM
ACGIH STEL:737 MG/M3;250 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL ETHYL KETONE
CAS:78-93-3
RTECS #:EL6475000
= Wt:20.
OSHA PEL:590 MG/M3;200 PPM
ACGIH TLV:590 MG/M3;200 PPM
ACGIH STEL:885 MG/M3;300 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CYCLOHEXANONE
CAS:108-94-1
RTECS #:GW1050000
OSHA PEL:200 MG/M3;50 PPM
ACGIH TLV:100 MG/M3;25 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:CHRONIC: SYMPTOMS OF RESPIRATORY TRACT
IRRITATION AND DAMAGE TO RESPIRATORY EPITHELIUM WERE REPORTED IN
RATS EXPOSED TO 5000 PPM THF FOR 90 DAYS. ELEVATION OF SGPT SUGGEST
A DISTURBANCE IN LIVER FUNCT ION. THE NOEL WAS REPORTED TO BE 200
PPM.
Effects of Overexposure:ACUTE:SEVERE OVEREXPOSURE MAY RESULT IN
NAUSEA, DIZZINESS, HEADACHE, CAN CAUSE DROWSINESS, IRRITATION OF
EYES AND NASAL PASSAGES. SKIN CONTACT: SKIN IRRITANT. LIQUID
CONTACT MAY REMOVE NATURAL SKIN OILS RESULTING IN SKIN IRRITATION.
DERMATITIS MAY OCCUR WITH PROLONG CONTACT.SKIN ABSORPTION:
PROLONGED OR WIDESPREAD EXPOSURE MAY RESULT IN THE ABSORPTION OF
HARMFUL AMOUNTS OF AMOUNTS OF MATERIAL S.EYE CONTACT:
OVEREXPOSURE MAY RESULT IN SEVERE EYE INJURY OR CONJUCTIVAL
INFLAMMATION ON CONTACT WITH LIQUID. VAPORS SLIGHTLY UNCOMFORTABLE.
INGESTION: MODERATELY TOXIC. MAY CAUSE NAUSEA, VOMITI NG,
DIARRHEA, MAY CAUSE MENTAL SLUGGISH
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING
DISEASE OF THE EYES, SKIN OR RESPIRATORY SYSTEM HAVE BEEN INCREASED
SUSCEPTIBILITY TO THE TOXICITY OF EXCESSIVE EXPOSURES.
===================== Fire Fighting Measures =====================
Lower Limits:2.0
Upper Limits:11.8
Extinguishing Media:ANSUL "PURPLE K" POTASSIUM BICARBONATE DRY
CHEMICAL, CARBON DIOXIDE, NATIONAL AER-O-FOAM UNIVERSAL ALCOHOL
RESISTANT FOAM, WATER SPRAY.
Fire Fighting Procedures:EVACUATE ENCLOSED AREAS. STAY UPWIND. CLOSE OR
CONFINED QUARTERS REQUIRE SELF-CONTAINED BREATHING APPARATUS,
POSITIVE PRESSURE HOSE MASK OR AIRLINE MASKS. USE WATER SPRAY TO
COOL CONTAINERS, TO FLUSH SPILLS FROM SOURCE OF IGNITION TO
DISPERSE VAPORS.
Unusual Fire/Explosion Hazard:FIRE HAZARD BECAUSE OF LOW FLASH POINT
AND HIGH VOLATILITY, VAPORS ARE HEAVIER THAN AIR MADE TRAVEL TO
SOURCE OF IGNITION.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. AVOID
BREATHING OF VAPORS. KEEP LIQUID OUT OF EYES. FLUSH WITH LARGE
AMOUNT OF WATER. CONTAIN LIQUID WITH SAND OR EARTH. ABSORB WITH
SAND OR NONFLAMMABLE ABSORBENT MATE RIAL AND TRANSFER INTO STEAL
DRUMS FOR RECOVERY OR DISPOSAL. PREVENT LIQUID FROM ENTERING
DRAINS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN THE SHADE BETWEEN 40F-100F.
KEEP AWAY FROM HEAT, SPARKS, OPEN FLAME AND SOURCES OF IGNITION.
AVOID PROLONGED BREATHING OF VAPOR. USE WITH ADEQUATE VENTILATION.
AVOID CONTACT WITH EYES, SKIN, AND CLOTHING. TRAIN EMPLOYEES ON
ALL SPECIAL HANDLING PROCEDURES BEFORE THEY WORK WITH THIS PRODUCT.
Other Precautions:FOLLOW ALL PRECAUTIONARY INFORMATION GIVEN ON
CONTAINER LABEL. PRODUCT BULLETINS AND OUR SOLVENT COMMENTING
LITERATURE. ALL HANDLING EQUIPMENT SHOULD BE ELECTRICALLY GROUNDED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ATMOSPHERIC LEVELS SHOULD BE MAINTAINED BELOW
ESTABLISHED EXPOSURE LIMITS CONTAIN IN SECTION II. IF AIRBORNE
CONCENTRATIONS EXCEED THOSE LIMITS, USE A NIOSH APPROVED ORGANIC
VAPOR CARTRIDGE WITH FULL FACE-PIECE IS RECOMMENDED. THE
EFFECTIVENESS OF AN AIR PURIFYING RESPIRATOR IS LIMITED. USE IT
ONLY FOR A SINGLE SHORT TERM EXPOSURE.
Ventilation:USE ONLY WITH ADEQUATE VENTILATION. PROVIDE SUFFICIENT
VENTILATION IN VOLUME AND PATTERN TO KEEP CONTAMINANTS BELOW
APPLICABLE EXPOSURE LIMITS.
Other Protective Equipment:IMPERVIOUS APRON AND A SOURCE OF RUNNING
WATER TO FLUSH OR WASH THE EYES AND SKIN IN CASE OF CONTACT
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:=66.1C, 151.F
Vapor Pres:143 MMHG
Vapor Density:2.49
Spec Gravity:0.976
Evaporation Rate & Reference:>1.0 (BUAC=1)
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR, WHITE OR GRAY, MEDIUM SYRUP LIQUID AND
ETHERAL ODOR
Percent Volatiles by Volume:70-80%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW LOCAL, STATE AND FEDERAL REGULATIONS.
CONSULT DISPOSAL EXPERT. CAN BE DISPOSED OF BY INCINERATION.
EXCESSIVE QUANTITIES SHOULD NOT BE PERMITTED TO ENTER DRAINS. EMPTY
CONTAINERS SHOULD BE AIR D RIED BEFORE DISPOSING.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TONER
CAGE:IO675
CAGE:S4183
CAGE:IO675
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE ACRYLIC COPOLYMER
CAS:25153-46-2
Fraction by Wt: 40-50%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:IRON OXIDE; (MAGNETITE)
CAS:1317-61-9
Fraction by Wt: 40-45%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:METAL-COMPLEX AZO-DYE (MFR CAS NO:88377-66-6)
CAS:85179-66-8
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PROPENE POLYMERS; (LOW MOLECULAR-WEIGHT POLYPROPYLENE)
CAS:9003-07-4
RTECS #:UD1842000
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE KNOWN WHEN USED AS INTENDED IN A
COPY MACHINE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:IRRITATION OF EYES AND RESPIRATORY TRACT MAY
OCCUR IN HEAVY DUST CONDITIONS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:REMOVE FROM EXPOSURE. INHAL:REMOVE TO FRESH AIR. SUPPORT
BREATHING (GIVE O2/ARTF RESP) . SKIN:WASH WITH SOAP. EYES:FLUSH
WITH WATER FOR AT LEAST 15 MINUTES. INGEST:DRINK WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL, CO2.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . COOL FIRE EXPOSED CONTAINER WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:MATERIAL CAN FROM EXPLOSIVE MIXTURES WHEN
SUSPENDED IN AIR. ALL IGNITION SOURCES SHOULD BE AVOIDED.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM OR SWEEP UP AS WITH ANY NON-TOXIC
POWDER. AVOID BREATHING DUST IF SAMPLE IS SPILLED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE NEXT TO STRONG OXIDIZERS.
Other Precautions:AVOID EXCESSIVE EXPOSURE TO HEAT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NONE REQUIRED WHEN PRODUCT IS USED AS
INTENDED.
Ventilation:LOCAL/MECH:NORMAL OFFICE CONDITIONS.
Other Protective Equipment:NONE IF PRODUCT IS USED AS INTENDED.
Work Hygienic Practices:AVOID BREATHING DUST IF SAMPLE IS SPILLED.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:275F,135C
Spec Gravity:1.6 (H20=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK POWDER, FAINT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE WITH COMMON MATERIALS WITH WHICH THE PRODUCT MAY REASONABLY COME
INTO CONTACT.
Stability Condition to Avoid:AVOID OPEN FLAME.
Hazardous Decomposition Products:TOXIC DECOMPOSITION PRODUCTS FORMED ON
COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE ACCORDING TO FEDERAL, STATE AND LOCAL
REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:UNIVOLT 60 ;INSULATING OIL
CAGE:EO384
CAGE:4H542
CAGE:EO384
============= Composition/Information on Ingredients =============
Ingred Name:COMPLEX MIXTURE OF PETROLEUM HYDROCARBONS (TAKE TLV AS OIL
MIXTURE)
ACGIH TLV:5MG/CUM(OILMIST
===================== Hazards Identification =====================
Effects of Overexposure:PROLONGED OR REPEATED CONTACT MAY CAUSE SKIN
IRRITATION ALSO MAY CAUSE MILD EYES IRRITATION.
======================= First Aid Measures =======================
First Aid:INHALE:REMOVE TO FRESH AIR, GIVE CPR/O*2 IF
NEED;EYES/SKIN:FLUSH W LG AMTS H*2O FOR 15 MIN;INGEST:RINSE MOUTH;
GET MEDICAL ATTENTION FOR EYES, BREATHING DIFFICULTY, OR OTHER
SYMPTOMS OF OVEREXPOSURE.
===================== Fire Fighting Measures =====================
Flash Point:320F/160C(C.O.C)
Lower Limits:1.0
Upper Limits:7.0
Extinguishing Media:FOAM,DRY CHEMICAL,CO*2,OR WATER FOG OR SPRAY
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA IN AN ENCLOSED
AREA.
Unusual Fire/Explosion Hazard:DO NOT MIX OR STORE WITH STRONG OXIDANTS
LIKE LIQUID CL*2 OR CONC.O*2
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;USE SUITABLE
ABSORBENT(LIKE SAND,EARTH,SAWDUST ETC.)AND RECOVER FOR PROPER
DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL DRY AND WELL VENTILATED
AREA.KEEP AWAY FROM HEAT,OPEN FLAMES AND OXIDIZERS.KEEP CONTAINERS
CLOSED WHEN NOT IN USE.
Other Precautions:AVOID CONTACT WITH EYES AND SKIN;DO NOT BREATHE
VAPORS/MIST.WASH THOROUGHLY AFTER EACH USE.DO NOT USE CONTAMINATED
CLOTHES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR
ORG.VAPORS/MIST IF > TLV.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:FULL WORK CLOTHING TO PREVENT REPEATED OR
PROLONGED CONTACT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:650F/343C
Vapor Pres:<.1
Vapor Density:8.9
Spec Gravity:0.878
Evaporation Rate & Reference:<0.01 (N-BUT/ACE=1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WATER WHITE COLORED LIQUID
Percent Volatiles by Volume:NEGL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS LIKE LIQ.CL*2,CONC.O*2,NA OR CA HYPOCHLORIT
Stability Condition to Avoid:EXTREME TEMPERATURES.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION:FUMES, SMOKE,CO
AND OXIDES OF SULFUR
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF COLLECTED MATERIAL IN ACCORDANCE WITH
LOCAL,STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TETRAMETHYLENE SULFONE, 99%, T2220-9
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:THIOPHENE, TETRAHYDRO-, 1,1-DIOXIDE; (TETRAMETHYLENE
SULFONE, 99%)
CAS:126-33-0
RTECS #:XN0700000
Fraction by Wt: 99%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL, RAT)1941 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF SWALLOWED, INHALED, OR
ABSORBED THROUGH SKIN. VAPOR OR MIST IS IRRITATING TO THE EYES,
MUCOUS MEMBRANES AND UPPER RESPIRATORY TRACT. CAUSES SKIN
IRRITATION. TO THE BEST OF MANUFACTURER'S KN OWLEDGE, THE CHEMICAL,
PHYSICAL AND TOXICOLOGICAL PROPERTIES HAVE NOT BEEN THOROUGHLY
INVESTIGATED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH EYES WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST
15 MINUTES. SEEK MEDICAL ADVICE. SKIN: IMMEDIATELY WASH SKIN WITH
SOAP AND COPIOUS AMOUNTS OF WATER. INHALATION: REMOVE TO FRESH AIR.
IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS
DIFFICULT, GIVE OXYGEN. INGESTION: WASH OUT MOUTH WITH WATER
PROVIDED PERSON IS CONSCIOUS. CALL MD. WASH CONTAMINATED CLOTHING
BEFORE REUSE.
===================== Fire Fighting Measures =====================
Flash Point:330F,166C
Extinguishing Media:WATER SPRAY. CARBON DIOXIDE, DRY CHEMICAL POWDER OR
APPROPRIATE FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS,
ASH, PICK UP, KEEP IN A CLOSED CONTAINER AND HOLD FOR WASTE
DISPOSAL. VENTILATE AREA AND WASH SPILL SITE AFTER MATERIAL PICKUP
IS COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:IRRITANT. HARMFUL SOLID OR LIQUID
(PHYSICAL STATE IS TEMPERATURE DEPENDENT). KEEP TIGHTLY CLOSED.
STORE IN A COOL DRY PLACE.
Other Precautions:DO NOT BREATHE VAPOR. DO NOT GET IN EYES, ON SKIN, ON
CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH WHICH MEET ANST
DESIGN CRITERIA . WEAR SUITABLE PROTECTIVE CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:545F,285C
Melt/Freeze Pt:M.P/F.P Text:80.6F,27.0C
Vapor Pres:0.01 @ 20C
Vapor Density:4.2
Spec Gravity:1.261
Appearance and Odor:WHITE SOLID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF: CARBON MONOXIDE,
CARBON DIOXIDE, SULFUR OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE OR MIX THE MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. OBSERVE ALL FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1R302
CAGE:26921
CAGE:26921
============= Composition/Information on Ingredients =============
Ingred Name:SELENIUM (SARA 313) (CERCLA)
CAS:7782-49-2
RTECS #:VS7700000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 MG/M3
ACGIH TLV:0.2 MG/M3; 9495
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:POLYVINYL CARBAZOLE
CAS:25067-59-8
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
Ingred
Name:N,N'-BIS(3-METHYLPHENYL)-N,N'-DIPHENYL-(1,1'-BIPHENYL)-4,4'-DI
AMINE
CAS:65181-78-4
Fraction by Wt: 10-15%
Other REC Limits:NONE RECOMMENDED
Ingred Name:CARBONIC ACID POLY / 4,4-(1-METHYLETHYLIDENE)BISPHENOL
CAS:25037-45-0
Fraction by Wt: 20-25%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLY(OXYETHYLENEOXYTEREPHTHALOYL)
CAS:25038-59-9
RTECS #:TR2725000
Fraction by Wt: 65-70%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT ESTABLISHED.
ACGIH TLV:NOT ESTABLISHED.
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS >5000 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:PRACTICALLY NON-TOXIC. NOT AN
IRRITANT. NOT A SENSITIZER. CHRONIC:MUTAGENICITY NOT DETECTED,
CARCINOGENS NOT PRESENT.
Explanation of Carcinogenicity:NOE PRESENT.
Effects of Overexposure:MFR GAVE NO INFORMATION ON MSDS.
Medical Cond Aggravated by Exposure:NONE WHEN USED AS DESCRIBED BY
PRODUCT LITERATURE.
======================= First Aid Measures =======================
First Aid:SKIN:WASH WITH SOAP AND WATER.
===================== Fire Fighting Measures =====================
Flash Point:N.A.
Lower Limits:N.A.
Upper Limits:N.A.
Extinguishing Media:WATER, FOAM, CARBON DIOXIDE.
Fire Fighting Procedures:WHEN IN A MACHINE, TREAT AS ELECTRICAL FIRE.
Unusual Fire/Explosion Hazard:EXPOSURE TO HIGH TEMPERATURES CAN RESULT
IN MELTING AND PYROLISIS. FUMES MAY CAUSE RESPIRATORY SYMPTOMS.
DELAYED EFFECTS MAY OCCUR UP TO 72 HOURS.
================== Accidental Release Measures ==================
Spill Release Procedures:PARTICLES DETACHED THROUGH PHYSICAL DAMAGE MAY
BE DISPOSED OF AS INDICATED BELOW.
Neutralizing Agent:MFR GAVE NO INFORMATION ON MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID EXPOSURE TO HIGH TEMPERATURES.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN XEROX
EQUIPMENT.
Ventilation:NONE REQUIRED WHEN USED AS INTENDED IN XEROX EQUIPMENT.
Other Protective Equipment:NONE REQUIRED WHEN USED AS INTENDED IN XEROX
EQUIPMENT.
Work Hygienic Practices:MFR:? HMIS:USE GOOD INDUSTRIAL HYGIENE
PRACTICE. AVOID UNNECESSARY CONTACT. WASH THOROUGHLY AFTER
HANDLING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NONE
Boiling Pt:B.P. Text:N.A.
Melt/Freeze Pt:M.P/F.P Text:N.A.
Vapor Pres:N.A.
Vapor Density:N.A.
Spec Gravity:N.A.
pH:N.A.
Evaporation Rate & Reference:N.A.
Solubility in Water:INSOLUBLE
Appearance and Odor:SOLID/ODORLESS
Percent Volatiles by Volume:N.A.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG MINERAL ACIDS.
Stability Condition to Avoid:FLAMES, DIRECT HEAT.
Hazardous Decomposition Products:OXIDES OF SELENIUM.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:CASUAL DISPOSAL LEADING TO INCINERATION OR
REGULAR LANDFILL I/A/W LOCAL, STATE AND FEDERAL REGULATIONS.
COUSTOMERS ARE ENCOURAGED TO RETURN SPENT UNIT TO XEROX CORP FOR
RECYCLING. CALL 800-822-2200 FO R INFORMATION.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:VOC-COMPLIANT PRIMERS AND TOPCOATS, V7777
CAGE:08882
CAGE:08882
============= Composition/Information on Ingredients =============
Ingred Name:XYLENE (SARA 313) (CERCLA) LEL:1.0%; VP:9.5 @ 20C
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 5-25%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (SARA 313) (CERCLA) LEL:1.2%; VP:22.0 @ 20C
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 0-45%
OSHA PEL:200 PPM
ACGIH TLV:S, 50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (AROMATIC
HYDROCARBON) LEL:1.0%; VP:4.0 @ 20C
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 0-30%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:N/K
Ingred Name:BENZENE, ETHYL-; (ETHYL BENZENE) (SARA 313) LEL:1.2%;
VP:10.0 @ 20C
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 0-5%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/125STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HYDROCARBON PROPELLANT/(PROPANE/BUTANE/ISOBUTANE) LEL:1.8%;
VP:52 PSIA @ 20C
CAS:68476-86-8
Fraction by Wt: 25%
OSHA PEL:1000 PPM (MFR)
ACGIH TLV:1000 PPM (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:HARMFUL IF INHALED. MAY
AFFECT BRAIN/NERV SYS, CAUSING DIZZ, HDCH/NAUS. RPTD OVEREXP MAY
PROGRESSIVELY LEAD TO STAG GAIT, CONFUSN, UNCON/COMA. CAUSES NOSE &
THROAT IRRIT. SKIN/EYE CONT:CAU SES SKIN & EYE IRRIT WHICH CAN LEAD
TO DERM W/RPTD OVEREXP. INGEST:MAY CAUSE GI IRRIT, NAUS, VOMIT &
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:DIARR. CHRONIC:TOLUENE APPEARS ON
NAVY OCCUP CHEM REPRO HAZS LIST. SEEK CONSULTATION FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG & EXPOS
INFO . RPTS HAV E ASSOC RPTD & PRLNGD OCCUP OVEREXP TO SOLVS W/PERM
BRAIN & NERV SYS DMG. OVEREXP TO XYLENE & TOLUENE IN LAB (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOS, RESTORE BRTHG & NOTIFY MD. EYE
CONT:FLUSH IMMED W/LG AMTS OF WATER FOR AT LST 15 MIN. NOTIFY MD.
SKIN CONT:WASH AFFECTED AREA W/SOAP & WATER, REMOVE CONTAM CLTHG &
WASH BEFORE REUSE. INGEST:DO NOT INDUCE VOMIT. KEEP PERSON WARM,
QUIET & GET MED ATTN. ASPIR OF MATL INTO LUNGS CAN CAUSE CHEM PNEUM
WHICH CAN BE FATAL.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:<0F,<-18C
Lower Limits:SEE INGS
Extinguishing Media:NFPA CLASS B EXTINGUISHERS (CARBON DIOXIDE, DRY
CHEMICAL OR FOAM).
Fire Fighting Procedures:WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER SPRAY MAY BE INEFTIVE. WATER MAY BE USED TO COOL CLSD CNTNRS
TO PVNT PRESS BUILD-UP & POSSIBLE (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPKS & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. DO NOT APPLY TO HOT SURFS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION, VENTILATE AREA
AND REMOVE WITH INERT ABSORBENT AND NON-SPARKING TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. DO NOT
PUNCTURE CONTAINERS. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING AND INHALING THE CONTENTS CAN BE HARMFUL/FATAL.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED CHEMICAL CARTRIDGE RESPIRATOR
(TC23C) TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY AND ORGANIC
VAPORS DURING SPRAY APPLICATION. IN CONFINED AREAS:USE NIOSH
APPROVED SUPPLIED-AIR RESPIRATORS OR HOODS (TC19C).
Ventilation:PROVIDE GENERAL DILUTION OR LOCAL EXHAUST VENTILATION IN
VOL & PATTERN TO KEEP TLVS OF HAZ INGS BELOW ACCEPTABLE LIMS.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER . USE IMPERVIOUS CLOTHING TO PREVENT PROLONGED SKIN CONTACT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC:AUTOIGNITION OR EXPLOSION. IF WATER IS USED, FOG
NOZZLES ARE PREFERRED. EFTS OF OVEREXP:ANIMALS HAS BEEN ASSOC
W/LIVER ABNORMS, KIDNEY, LUNG, SPLEEN & EYE DMG AS WELL AS ANEMIA.
EFTS I N HUMANS HAVE INCLUDED LIVER & CARDIAC ABNORMS. PRODS CNTN
CHEM KNOWN TO CA TO CAUSE BIRTH DEFECTS/OTHER REPRO HARM.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:<0F,<-18C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER (ETHER=1)
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY OPEN FLAME-CARBON MONOXIDE AND
CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL, STATE AND FEDERAL
REGULATIONS. DO NOT INCINERATE CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RHODORSIL FLUID 47V100 THROUGH 2500000
CAGE:LO755
CAGE:LO755
Contract Num:SP0450-01-M-LQ28
CAGE:2B613
============= Composition/Information on Ingredients =============
Ingred Name:POLY(DIMETHYL)SILOXANES
CAS:63148-62-9
RTECS #:JT6484500
===================== Hazards Identification =====================
LD50 LC50 Mixture:NO DATA PROVIDED BY MANUFACTURER
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-EYE: NON-IRRITATING. MAY CAUSE
FOREIGN BODY IRRITATION ONLY. ACUTE SKIN: NON-IRRITATING. LOW ACUTE
DERMAL TOXICITY. ACUTE-INHALATION: INHALATION NOT LIKELY. ACUTE
INGESTION: LOW ACUTE ORAL TOXIC ITY. CHRONIC EFFECTS: THIS PRODUCT
DOES NOT CONTAIN ANY INGREDIENT DESIGNATED BY IARC, NTP, ACGIH OR
OSHA AS PROBABLE OR SUSPECTED HUMAN CARCINOGENS.
Explanation of Carcinogenicity:THIS PRODUCT DOES NOT CONTAIN ANY
INGREDIENT DESIGNATED BY IARC, NTP, ACGIH OR OSHA AS PROBABLE OR
SUSPECTED HUMAN CARCINOGENS.
Effects of Overexposure:ACUTE-EYE: NON-IRRITATING. MAY CAUSE FOREIGN
BODY IRRITATION ONLY. ACUTE SKIN: NON-IRRITATING. LOW ACUTE DERMAL
TOXICITY. ACUTE-INHALATION: INHALATION NOT LIKELY. ACUTE INGESTION:
LOW ACUTE ORAL TOXIC ITY.
Medical Cond Aggravated by Exposure:NO SPECIFIC INFORMATION FOUND.
======================= First Aid Measures =======================
First Aid:EYE: IN CASE OF CONTACT, IMMEDIATELY ABSORB EXCESS WITH CLEAN
ABSORBENT CLOTH OR COTTON. THEN, HOLD EYELIDS OPEN & FLUSH WITH A
STEADY, GENTLE STREAM OF WATER FOR AT LEAST 15 MINUTES. SEEK
MEDICAL ATT ENTION IF IRRITATION DEVELOPS OR PERSISTS OR IF VISUAL
CHANGES OCCUR. SKIN: IMMEDIATELY WIPE EXCESS MATERIAL OFF SKIN WITH
A DRY CLOTH; THEN WASH SKIN WITH PLENTY OF SOAP & WATER. SEEK
MEDICAL ATTENTI ON IF IRRITATION DEVELOPS OR PERSISTS. INHALATION:
INHALATION IS NOT AN EXPECTED ROUTE OF EXPOSURE. IF RESPIRATORY
IRRITATION OR DISTRESS OCCURS REMOVE VICTIM TO FRESH AIR. SEEK
MEDICAL ATTENTION IF RESPIRATORY IRRITATION OR DISTRESS
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>300.C, 572.F
WILL BURN
Lower Limits:NO DATA
Upper Limits:NO DATA
Extinguishing Media:DRY CHEMICAL, FOAM, CARBON DIOXIDE.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR NIOSH/MSHA APPROVED
SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING.
COOL CONTAINERS EXPOSED TO FIRE WITH WATER.
Unusual Fire/Explosion Hazard:PRODUCT WILL BURN UNDER FIRE CONDITIONS.
HAZARDOUS DECOMPOSITION MATERIALS (UNDER FIRE CONDITIONS):
FORMALDEHYDE, OXIDES OF CARBON, SILICA (CRYSTALLINE).
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR APPROPRIATE PROTECTIVE GEAR FOR THE
SITUATION. SPILLED MATERIAL MAY MAKE THE FLOOR SLIPPERY. DO NOT
LEAVE TRACES OF PRODUCT ON FLOORS, LADDERS, ETC., AS THIS MAY
PRESENT A SLIPPING HAZARD. ABSORB WITH AN INERT ABSORBENT. SCRAPE
UP AND PLACE IN APPROPRIATE CLOSED CONTAINER. CLEAN UP RESIDUAL
MATERIAL WITH AN APPROPRIATE SOLVENT LIKE PAINT THINNER OR MINERAL
SPIRITS, PROVIDED THAT THERE IS GOOD
Neutralizing Agent:NO DATA PROVIDED BY MANUFACTURER
======================Handling and Storage ======================
Handling and Storage Precautions:MINIMUM / MAXIMUM STORAGE
TEMPERATURES: 5 TO 25C (41 TO 77F). AVOID DIRECT OR PROLONGED
CONTACT WITH SKIN AND EYES. STORE IN TIGHTLY CLOSED CONTAINERS.
RECOMMENDED CONTAINER MATERIAL: EPOXY-COATED STE EL, ORDINARY
STEEL, POLYETHYLENE. STORE IN AN AREA THAT IS DRY, WELL-VENTILATED.
Other Precautions:ANY CONTAINERS OR EQUIPMENT USED SHOULD BE
DECONTAMINATED IMMEDIATELY AFTER USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN RESPIRATORS ARE REQUIRED, SELECT NIOSH/MSHA
APPROVED EQUIPMENT BASED ON ACTUAL OR POTENTIAL AIRBORNE
CONCENTRATIONS AND IN ACCORDANCE WITH THE APPROPRIATE REGULATORY
STANDARD AND/OR INDUSTRIAL RE COMMENDATIONS. FOR REASONABLY
FORESEEABLE INDUSTRIAL AND USES OF THIS MATERIAL, RESPIRATORY
PROTECTION SHOULD NOT BE NCECESARY.
Ventilation:GENERAL AREA DILUTION/EXHAUST VENTILATION.
UPON WORK ENVIRONMENT
Other Protective Equipment:SUITABLE LONG-SLEEVED CLOTHING (I.E., SHIRTS
AND PANTS). CONSIDERATION MUST BE GIVEN BOTH TO DURABILITY AS WELL
AS PERMEATION RESISTANCE.
Work Hygienic Practices:DO NOT STORE, USE &/OR CONSUME FOODS,
BEVERAGES, TOBACCO PRODUCTS, OR COSMETICS IN AREAS WHERE THIS
MATERIAL IS STORED. WASH HANDS & FACE CAREFULLY BEFORE EATING,
DRINKING, USING TOBACCO.
Supplemental Safety and Health
THESE RECOMMENDATIONS PROVIDE GENERAL GUIDANCE FOR HANDLING THIS
PRODUCT. BECAUSE SPECIFIC WORK ENVIRONMENTS & MATERIAL HANDLING
PRACTICES VARY, SAFETY PROCEDURES SHOULD BE DEVELOPED FOR EACH
INTENDED APPLICATION. WHILE DEVELOPING SAFEHANDLING PROCEDURES, DO
NOT OVERLOOK THE NEED TO CLEAN EQUIPMENT AND PIPING SYSTEMS
================== Physical/Chemical Properties ==================
HCC:V5
Boiling Pt:B.P. Text:NOT AVAILABLE
Melt/Freeze Pt:<-54.C, -65.2F
Vapor Pres:<0.01 MMHG @200C (392F)
Spec Gravity:>0.96 @ 25C(77F)
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR, VISCOUS LIQUID; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES, STRONG ACIDS, STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, OPEN FLAME, SPARK.
Hazardous Decomposition Products:DECOMPOSITION TYPE:
THERMAL-DIMETHYLCYCLOSILOXANES, METHYLPHENYLCYCLOSILOXANES.
DECOMPOSITION TYPE: OXIDATIVE/THERMAL: FORMALDEHYDE
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:TOXICOLOGICAL INFORMATION AND INTERPRETATION:
EYE-EYE IRRITATION, RABBIT; NON-IRRITATING. SKIN: SKIN IRRITATION,
RABBIT: NON-IRRITATING. LD50 >5000 MG/M3, RAT. NO DEATHS OBSERVED.
ACUTE RESPIRATORY IR RITATION: NO TEST DATA FOUND FOR PRODUCT.
ACUTE INHALATION TOXICITY: NO TEST DATA FOUND FOR PRODUCT. ACUTE
ORAL TOXICITY: LD50 > 5000 MG/KG, RAT. NO DEATHS OBSERVED. CHRONIC
TOXICITY: UNDER CERTAIN CO NDITIONS, THIS PRODUCT MAY GENERATE
FORMALDEHYDE. FORMALDEHYDE IS LISTED AS A POTENTIAL HUMAN
CARCINOGEN BY IARC, OSHA AND ACGIH.
===================== Ecological Information =====================
Ecological:ECOTOXICOLOGICAL INFORMATION: NO DATA FOUND FOR PRODUCT.
CHEMICAL FATE INFORMATION: NO DATA FOUND FOR PRODUCT.
==================== Disposal Considerations ====================
Waste Disposal Methods:CHEMICAL ADDITIONS, PROCESSING OR OTHERWSE
ALTERING THIS MATERIAL MAY MAKE THE WASTE MANAGEMENT INFORMATION
PRESENTED IN THIS MSDS INCOMPLETE, INACCURATE OR OTHERWISE
INAPPROPRIATE. STATE & LOCAL REQU IREMENTS FOR WASTE DISPOSAL MAY
BE MORE RESTRICTIVE OR OTHERWISE DIFFERENT FROM FEDERAL LAWS &
REGUL ATIONS. EPA HAZARDOUS WASTE: NO.
=================== MSDS Transport Information ===================
Transport Information:NOT REGULATED.
===================== Regulatory Information =====================
SARA Title III Information:SARA TITLE III HAZARD CLASSES: FIRE HAZARD -
NO. REACTIVE HAZARD - NO. RELEASE OF PRESSURE - NO. ACUTE HEALTH
HAZARD - NO. CHRONIC HEALTH HAZARD - NO.
Federal Regulatory Information:TSCA INVENTORY STATUS: ALL FUNCTIONAL
COMPONENTS OF THIS PRODUCT ARE LISTED ON THE TSCA INVENTORY.
State Regulatory Information:THIS PRODUCT DOES NOT CONTAIN ANY
COMPONENTS THAT ARE REGULATED UNDER CALIFORNIA PROPOSITION 65.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PR-1428 A-2, BASE
Kit Part:Y
Preparer's Name:SEROJE HARTOONIANI
CAGE:83574
CAGE:83574
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM DIOXIDE (LISTED AS REQ'D BY 29CFR 1910:1200, FULL
ENCAPSULATED, NOT HAZARDOUS UNDER NORMAL CIRCUMSTANCES)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 1.358%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:CALCIUM CARBONATE (LIMESTONE) (LISTED AS REQ'D BY 29 CFR
1910:1200, FULLY ENCAPSULATED, NOT HAZARDOUS WITH NORMAL USE)
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 21.050%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15.0 MG/M3
ACGIH TLV:10.0 MG/M3
Ingred Name:TOLUENE (SARA III) (VAPOR PRESSURE 23 MM HG)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 8.169%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM;STEL 150 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:POLYSULFIDE POLYMER (NON HAZARDOUS INGREDIENT)
CAS:68611-50-7
Other REC Limits:NONE RECOMMENDED
Ingred Name:BARIUM COMPOUND (NON HAZARDOUS INGREDIENT)
CAS:1103-38-4
Other REC Limits:NONE RECOMMENDED
Ingred Name:VOC PER EPA METHOD 24: 157 G/L (COMBINED PART A AND B)
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:MAY CAUSE
BURNING,TEARING,REDDENING. SKIN:PROLONGED EXPOSURE MAY CAUSE
DRYING,CRACKING & DERMATITIS. INHALATION: MAY CAUSE
DIZZINESS,DROWSINESS & FATIGUE. MAY CAUSE LIVER & KIDNEY DAMAGE.
INGESTIO N:MAY CAUSE DROWSINESS,DIZZINESS,NAUSEA. CHRONIC:MAY CAUSE
DISTURBANCE IN MEMORY,THINKING ABILITY,EMOTIONS & COORDINATIO
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES, IF SYMPTOMS PERSIST,
CONSULT A PHYSICIAN. SKIN: WASH WITH SOAP AND WATER. IF SYMPTOMS
PERSISTS, CONSULT A PHYSICIAN. INHALATION: REMOVE TO FRESH AIR. IF
SYMPTOMS ARE PRESENT, CONSULT A PHYSICIAN. INGESTION: CONSULT A
PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:72.0F,22.2C
Lower Limits:1.3
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER SPRAY
Fire Fighting Procedures:USE AIR SUPPLIED RESPIRATOR. USE WATER TO COOL
HEAT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:HIGH TEMPERATURE MAY CAUSE PRESSURE
BUILDUP IN CLOSED CONTAINER.
================== Accidental Release Measures ==================
Spill Release Procedures:PROTECT FROM IGNITION. WEAR AIR SUPPLIED
RESPIRATOR FOR MAJOR UNVENTILATED SPILL. CLEAN-UP RESIDUE WITH A
SUITABLE SOLVENT. CERCLA RQ FOR TOLUENE IS 1,000 LBS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. DO NOT
STORE ABOVE 120F. GROUNDING & BONDING PROCEDURES SHOULD BE FOLLOWED
WHEN TRANSFERING MATERIAL. AVOID INGESTION.
Other Precautions:EMPTY DRUMS MAY CONTAIN EXPLOSIVE VAPORS. DO NOT CUT,
PUNCTURE OR WELD ON OR NEAR DRUM. VAPORS OF THIS PRODUCT ARE
HEAVIER THAN AIR AND MAY COLLECT IN LOW OR CONFINED AREAS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN SPRAYING OR APPLYING IN ANY CIRCUMSTANCES
LIKELY TO PRODUCE AIRBORNE LEVEL OF HAZARDOUS INGREDIENTS IN EXCESS
OF TLV, USE AN ORGANIC VAPOR CARTRIDGE OR AIR SUPPLIED RESPIRATOR.
Ventilation:GENERAL VENTILATION TO MAINTAIN VAPORS BELOW PEL.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
SMOKING OR EATING.
Supplemental Safety and Health
KEY1:F3.
================== Physical/Chemical Properties ==================
HCC:F2
Vapor Density:> AIR
Spec Gravity:1.39
Viscosity:150P #6@10RPM
Evaporation Rate & Reference:< N-BUTYL ACETATE
Solubility in Water:SLIGHT
Appearance and Odor:REDDISH LIQUID
Percent Volatiles by Volume:13.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NOT KNOWN
Hazardous Decomposition Products:OXIDES OF CARBON, SULFUR DIOXIDE,
TRACES OF HYDROGEN SULFIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:EPA NO. D-001 HAZARDOUS WASTE. DISPOSE OF IN
COMPLIANCE WITH FEDERAL AND STATE REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-H-6083E
Preparer's Name:N.R.NETZEL
CAGE:VELSI
CAGE:0Z6C4
CAGE:VELSI
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM HYDROCARBON BASE
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV FOR OIL MIST IS 5MG/M3
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:MISTS FROM EXCESSIVE HEATING MAY
CAUSE IRRITATION.SKIN:LOW DERMAL TOXICITY.MISTS FROM EXCESSIVE
HEATING MAY CAUSE IRRITATION.INGEST:LOW ORAL TOXICITY.INHAL:MAY
CAUSE RESPIRATORY IRRITATION.
Explanation of Carcinogenicity:NONE OF THE INGREDIENTS IN THIS PRODUCT
IS LISTED BY NTP, IARC OR OSHA AS A CARCINOGEN.
Effects of Overexposure:NAUSEA,VOMITING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH SOAP AND
WATER.EYES:FLUSH WITH WATER FOR 15 MINUTES.CALL PHYSICIAN IF
IRRITATION DEVELOPS.INHAL:REMOVE TO FRESH AIR.GIVE OXYGEN OR
ARTIFICIAL RESPIRATION IF NEEDED.INGEST:DO NOT INDUCE VOMITING.GET
PROMPT QUALIFIED MEDICAL ATTENTION.NOTE TO PHYSICIAN:TREAT
SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:200F,93C
Extinguishing Media:WATER FOG,DRY CHEMICAL,CARBON DIOXIDE,FOAM.AVOID
SPREADING BURNING LIQUID WITH WATER STREAM.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.HEAT OF FIRE MAY CAUSE
CONTAINERS TO BURST.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP WITH NON-COMBUSTIBLE INERT
ADSORBANT(EG.CLAY);PLACE COLLECTED MATERIAL IN AN APPROPRIATE
CONTAINER FOR DISPOSAL;CLEAN SPILL AREA TO REMOVE SLIPPERINESS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP AWAY FROM SOURCES OF IGNITION AND STRONG
OXIDANTS. KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:AVOID EYE AND SKIN CONTACT. DO NOT BREATHE VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. NIOSH/MSHA-APPROVED
RESPIRATOR OR SCBA AS APPROPIATE FOR EXPOSURE OF CONCERN.
Ventilation:NO SPECIAL REQUIREMENTS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS.SEPERATE WORK CLOTHES FROM STREET
CLOTHES.LAUNDER WORK CLOTHES BEFORE REUSE.KEEP FOOD OUT OF THE WORK
AREA.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:420F,216C
Vapor Pres:0.07@68F
Vapor Density:>1
Spec Gravity:<1
Evaporation Rate & Reference:NOT VOLATILE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:RED CLEAR LIQUID,SLIGHT PETROLEUM ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:UNIDENTIFIED TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL,STATE AND LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:020806, MINERAL SPIRITS
CAGE:02186
CAGE:02186
============= Composition/Information on Ingredients =============
Ingred Name:HYDROTREATED HEAVY NAPHTHA (PETROLEUM); (PETROLEUM NAPTHA)
CAS:64742-48-9
Fraction by Wt: 100%
OSHA PEL:500 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:CAN CAUSE SEVERE IRRITATION. SKIN:
CONTACT CAN CAUSE IRRITATION, DEFATTING, DERMATITIS. INHAL:CAN
CAUSE IRRITATION, DIZZINESS, NAUSEA, HEADACHE. INGEST:CAN CAUSE
GASTROINTESTINAL IRRITATION, NAUSE A, VOMITING, AND DIARRHEA.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:INGEST:CALL PHYSICIAN. DO NOT INDUCE VOMITING. INHAL:REMOVE
PERSON TO FRESH AIR. GIVE ARTIFICIAL RESPIRATION IF BREATHING IS
INTERRUPTED. EYE:FLUSH WITH WATER FOR AT LEAST 15 MINUTES. GET
MEDICAL ATTE NTION. SKIN:WASH WITH SOAP AND WATER.
===================== Fire Fighting Measures =====================
Flash Point:105F,41C
Lower Limits:0.8%
Upper Limits:5.0%
Extinguishing Media:FOAM, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:PREVENT IGNITION, STOP LEAK: VENTILATE AREA.
ABSORB WITH INERT MATERIAL, CONTAINERIZE FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM SPARKS AND OPEN FLAMES.
AVOID PROLONGED SKIN CONTACT.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED SELF-CONTAINED BREATHING
APPARATUS.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:NONE
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:>300F,149C
Vapor Pres:6
Vapor Density:3.9
Spec Gravity:0.79 (H2O=1)
Evaporation Rate & Reference:70
Solubility in Water:NIL
Appearance and Odor:CLEAR, COLORLESS SOLVENT ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, SPARKS, AND FLAMES.
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:LIQUID INCINERATION. CONTAMINATED ABSORBENT MAY
BE DEPOSITED IN A LANDFILL IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: SHIPPING-MATE PALLETIZING ADHESIVE
Cage: 52152
Resp. Party Other MSDS No.: 05-5202-6
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 52152
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYE: MODERATE IRRITANT: SIGNS/SYMPTOMS INCLUDE REDNESS,
SWELL, PAIN, TEARING, & HAZY VISION. SKIN: MILD IRRITANT (AFTER
PROLONGED, REPEATED CONTACT): SIGNS/SYMPTOMS INCLUDE REDNESS, SWELLING, &
ITCHIN G. INHALATION: INTENTIONAL CONCENTRATION & INHALATION MAY BE
HARMFUL/FATAL. SIGNS/SYMPTOMS OF INHALATION: KIDNEY EFFECTS: INCLUDE REDUCED
URINE VOLUME, BLOOD IN URINE & BACK PAIN; LIVER EFFECTS: INCLU DE YELLOW
SKIN (JAUNDICE) & TENDERNESS OF UPPER ABDOMEN .CNS DEPRESSION:
SIGNS/SYMPTOMS INCLUDE HEADACHE, DIZZINESS, DROWSINESS, SLOWED REACTION TIME,
INCOORDINATION, SLURRED SPEECH,GIDDINESS & UNCONS CIOUSNESS. IRRITATION
(OVEREXPOSURE)
Signs And Symptions Of Overexposure: ACUTE/CHRONIC (CONTD): (UPPER
RESPIRATORY): SIGNS/SYMPTOMS INCLUDE SORENESS OF NOSE & THROAT, COUGHING
& SNEEZING. INGESTION: NOT A LIKELY ROUTE OF EXPOSURE. WHILE THE
FOLLOWING EFFECTS ARE ASSOCIAT ED W/ONE OR MORE OF INDIVIDUAL INGRED IN
PRODUCT & ARE REQUIRED TO BE INCLUDED ON MSDS BY U.S. OSHA HAZARD
COMMUNICATION STANDARD, THEY ARE NOT EXPECTED EFFECTS DURING FORESEEABLE USE
OF PRODUCT. PERI PHERAL NEUROPATHY: SIGNS & SYMPTOMS INCLUDE TINGLING OF
EXTREMITIES, INCOORD, NUMBNESS, WEAKNESS & TREMORS. INGESTION MAY CAUSE
IRRITATION OF GI TISSUES: INCLUDING PAIN, VOMIT, ABDOMINAL TENDERNESS, N
AUSEA, BLOODY VOMITUS & BLOOD IN FECES.
First Aid: EYE CONTACT: IMMEDIATELY FLUSH EYES WITH LARGE AMOUNTS OF WATER FOR
AT LEAST 15 MINUTES. GET IMMEDIATE MEDICAL ATTENTION. SKIN CONTACT: FLUSH
SKIN WITH LARGE AMOUNTS OF WATER. IF IRRITATION PERSISTS, GET MEDICAL
ATTENTION. INHALATION: REMOVE PERSON TO FRESH AIR. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, GET IMMEDIATE MEDICAL
ATTENTION. INGESTION: DO NOT INDUCE VOMIT ING. DRINK TWO GLASSES OF WATER,
CALL A PHYSICIAN.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: VENTILATE AREA. EXTINGUISH ALL IGNITION SOURCES.
COVER WITH ABSORBENT MATERIAL. COLLECT USING NON-SPARKING TOOLS. PLACE IN U.
S. DOT-APPROVED CONTAINER. REFER TO OTHER SECTIONS OF THIS MSDS FOR INFORM
ATION REGARDING PHYSICIAL AND HEALTH HAZARDS, RESPIRATORY PROTECTION,
VENTILATION, AND PERSONAL PROTECTIVE EQUIPMENT.
Waste Disposal Methods: INCINERATE IN A PERMITTED HAZARDOUS WASTE INCINERATOR
IN THE PRESENCE OF A COMBUSTIBLE MATERIAL. FACILITY MUST BE CAPABLE OF
HANDLING AEROSOL CANS. DISPOSE OF EMPTY CANS IN A SANITARY LANDFILL. DISPOS E
OF WASTE PRODUCT IN A FACILITY PERMITTED TO ACCEPT CHEMICAL RECYCLE EMPTY
AEROSOL CONTAINERS WHER E AVAILABLE. DISPOSE IN ACCORDANCE (ECOLOGICAL)
Handling And Storage Precautions: AEROSOL CONTAINER CONTAINS FLAMMABLE GAS
UNDER PRESSURE. KEEP AWAY FROM HEAT, SPARKS, OPEN FLAME AND OTHER SOURCES OF
IGNITION. EXTREMELY FLAMMABLE LIQUID & VAPOR. DO NOT PIERCE OR BURN
CONTAINER, EVE N AFTER USE. NO SMOKING WHILE HANDLING THIS MATERIAL. AVOID
STATIC DISCHARGE. .(OTHER PRECAUTIONS)
Other Precautions: HANDLING/STORAGE PRECAUTIONS (CONT'): STORE AT TEMPERATURES
BELOW 120F (49C). STORE OUT OF DIRECT SUNLIGHT. KEEP OUT OF REACH OF
CHILDREN. DO NOT INGEST.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point: =-41.1C, -42.F
Autoignition Temp Text: N/D
Lower Limits: N/D
Upper Limits: N/D
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: WEAR NIOSH APPROVED FULL PROTECTIVE CLOTHING,
INCLUDING HELMET, SELF-CONTAINED POSITIVE PRESSURE OR PRESSURE DEMAND
BREATHING APPARATUS, BUNKER COAT AND PANTS, BANDS AROUND ARMS, WAIST AND
LEGS, FACE MASK, AND PROTECTIVE COVERING FOR EXPOSED AREAS OF THE HEAD.
Unusual Fire/Explosion Hazard: AEROSOL CONTAINERS CONTAIN FLAMMABLE GAS UNDER
PRESSURE. EXTREMELY FLAMMABLE LIQUID AND VAPOR. CLOSED CONTAINERS EXPOSED TO
HEAT FROM FIRE MAY BUILD PRESSURE AND EXPLODE. VAPORS MAY TRAVEL LONG DISTAN
CES ALONG THE GROUND OR FLOOR TO AN IGNITION SOURCE AND FLASH BACK.
=======================================================
Control Measures
=======================================================
Respiratory Protection: AVOID BREATHING VAPORS, MISTS OR SPRAY. SELECT ONE OF
THE FOLLOWING NIOSH APPROVED RESPIRATORS BASED ON AIRBORNE CONCENTRATION OF
CONTAMINANTS AND IN ACCORDANCE WITH OSHA REGULATIONS: HALF-MASK ORGANI C
VAPOR RESPIRATOR.
Ventilation: DO NOT USE IN CONFINED AREA OR AREAS WITH LITTLE OR NO AIR
MOVEMENT. IF EXHAUST VENTILATION IS NOT ADEQUATE, USE APPROPRIATE RESPIRATORY
(SUPP DATA)
CONTACT.
Other Protective Equipment: EYEWASH AND DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA (FP N).
Supplemental Safety and Health: VENTILATION (CONT'D): PROTECTION. PROVIDE
VENTILATION ADEQUATE TO CONTROL VAPOR CONCENTRATION . ID NUMBER/U.P.C.:
62-4685-4930-8, 00-21200-85844-4, 62-4685-4935-7.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: N/A.
M.P/F.P Text: N/A.
Vapor Pres: N/A.
Vapor Density: 2.97 AIR=1
Spec Gravity: .697, WATER=1.
PH: N/A.
Viscosity: N/A.
Evaporation Rate & Reference: 1.9 (ETHER=1)
Solubility in Water: NIL.
Appearance and Odor: AEROSOL, LIGHT CREAM COLORED LIQUID IN AEROSOL,
SWEET/FRUITY ODOR.
Percent Volatiles by Volume: < 75% BY WT.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEAT.
Hazardous Decomposition Products: CARBON MONOXIDE AND CARBON DIOXIDE, TOXIC
VAPORS, GASES OR PARTICULATES.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: WILL NOT OCCUR.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
Ecological: ENVIRONMENTAL DATA: NOT DETERMINED. WASTE DISPOSAL (CONT'D): WITH
ALL APPLICABLE FEDERAL, STATE, AND LOCAL REGULATIONS (FP N).
=======================================================
=======================================================
Transport Information: N/P. SOURCE OF EXPOSURE LIMIT DATA: ACGIH: AMERICAN
CONFERENCE OF GOVERNMENTAL INDUSTRIAL HYGIENISTS. AIHA: AMERICAN INDUSTRIAL
HYGIENE ASSOC. WORKPLACE ENVIRONMENTAL EXPOSURE LEVEL G.
OSHA: OCCUPATIO NAL SAFETY & HEALTH ADMINISTRATION. CMRG: CHEMICAL
MAUFACTURE RECOMMENDED GUIDELINES. NONE: NONE ESTABLISHED. INGREDIENTS:
DIMETHYL ETHER-VALUE: 1000; UNIT: PPM; TYPE: TWA; AUTH: CMRG. DIMETHYL EITHER
-VALUE:500; UNIT: PPM; TYPE: TWA; AUTH: AIHA. DIMETHYL ETHER-VALUE: 942;
UNIT: MG/M3; TYPE: TWA; AUTH: AIHA.
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: THIS PRODUCT CONTAINS THE FOLLOWING TOXIC CHEMICAL
OR CHEMICALS SUBJECT TO REPORTING REQUIREMENTS OF SECTION 313 OF TITLE III OF
EMERGENCY PLANNING & COMMUNITY RIGHT-TO-KNOW ACT OF 1986 AND 40 CFR PAR T
372: CYCLOHEXANE AND HEXANE.
Federal Regulatory Information: SINCE REGS VARY, CONSULT APPLIC REGS OR AUTH
BEFORE DISPOSAL. U.S. EPA HAZARDOUS WASTE NUMBER=D001 (IGNITABLE). EPCRA
HAZARD CLASS: FIRE HAZ: YES. PRESSURE: YES. REACTIVITY: NO. ACUTE: YES.
CHRONIC: Y ES. NON-VOLATILE COMPONENT-NEW JERSEY TRADE SECRET REGISTRY NO.
04499600-5902P++ IS SYNTHETIC POLYMER, TACKIFYING RESINS AND STABILIZERS. NOT
HAZARDOUS ACCORDING TO CANADIAN W CRITERIA. NON-W CONTROLLED.
State Regulatory Information: VOLATILE ORGANIC COMPOUNDS: <75% (582 G/L)
SCAQMD RULE 443.1, CALCULATED. VOC LESS H2O & EXEMPT SOLVENTS: CA. 75%
(582 G/L) SCAQMD RULE 443.1, CALCULATED.
=======================================================
Other Information
=======================================================
Other Information: NFPA: HEALTH-2, FIRE-4, REACTIVITY-0. : HEALTH-1,
FLAMMABILITY-4, REACTIVITY-0. AEROSOL STORAGE: 3. UNUSUAL REACTION HAZARD:
NONE. EXPOSURE LIMITS FOR DIMETHYL ETHER=1000 PPM TWA (CMRG); 500 PPM /942
MG/M3 (AIHA). *SKIN NOTATION: LISTED SUBSTANCES INDICATED WITH "Y" UNDER SKIN
(INGREDIENTS) REFER TO OVERALL EXPOSURE BY CUTANEOUS ROUTE INCL MUC MEMB
& EYE, BY AIRBORNE OR BY DIRECT CONTACT W/SU BSTANCE. VEHICLES CAN ALTER
SKIN ABSORPTION. ABREVIATIONS FOR THIS MSDS: N/D = NOT DETERMINED. N/A = NOT
APPLICABLE. CA = APPROXIMATELY.
=======================================================
HAZCOM Label
=======================================================
Product ID: SHIPPING-MATE PALLETIZING ADHESIVE
Cage: 52152
Company Name: MINNESOTA MINING & MFG CO INDUSTRIAL TAPE & SPECIALTIES
DIV
Street: 3M CENTER
Zipcode: 55144-1000
Label Required IND: Y
Date Of Label Review: 01/05/2001
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Severe
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: ACUTE/CHRONIC:EYE:MODERATE EYE IRRITANT. REDNESS,
SWELLING, PAIN, TEARING, HAZY VISION. SKIN: MILD SKIN IRRIT. AFTER PROLONGED,
REPEATED CONTACT: REDNESS, SWELLING & ITCHING. INHALATION: MAY BE HARMFU
L OR FATAL;KIDNEY EFFECTS INCL REDUCED URINE VOLUME, BLOOD IN URINE &
BACK PAIN; LIVER EFFECTS INCL YELLOW SKIN (JAUNDICE),TENDERNESS OF UPPER
ABDOMEN. CNS DEPRESION, HEADACHE, DIZZINESS, DROWSINESS, SLOWED REACTION
TIME, SLURRED SPEECH, INCOORDINATION, GIDDINESS & UNCONSCIOUSNESS. IRRIT
(UPPER RESP): SORENESS OF NOSE & THROAT, COUGHING, SNEEZING. POSSIBLE
PERIPHERAL NEUROPATHY. INGESTION: IRRIT O F GI TRACT, PAIN, VOMIT, BLOOD IN
VOMITUS & FECES.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CRYSTALLINE SILICA (QUARTZ)
CAGE:0PUU3
CAGE:0PUU3
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
OSHA PEL:N/K
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:SUPDAT: & WHICH INCREASES SUSCEPTIBILITY TO PULM
TUBERCULOSIS. PROGRESSIVE MASSIVE FIBROSIS MAY BE ACCOMPANIED (ING
3)
RTECS #:9999999ZZ
Ingred Name:ING 2: RIGHT HEART ENLARGEMENT, HEART FAILURE & PULMONARY
FAILURE. SMOKING AGGRAVATES EFFECTS OF EXPOSURE.
RTECS #:9999999ZZ
Ingred Name:OTHER PRECS: COLLECT ON WALLS, FLOORS, SILLS, LEDGES,
MACHINERY OR EQUIP. MAINTAIN CLEAN & FIT TEST RESPS I/A/W (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: OSHA REGS. MAINTAIN & TEST VENT & DUST COLLECTION
EQUIP. VACUUM OR WASH CLTHG WHICH HAS BECOME DUSTY. SEE (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:OSHA HAZ COMMUNICATION 29 CFR SECTIONS 1910.1200,
1915.99, 1917.28, 1926.59 & 1928.21 & STATE & LOC WORKER (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: OR COMMUNITY "RIGHT TO KNOW" LAWS & REGS. MFR RECOMS
SMOKING BE PROHIBITED IN ALL AREAS WHERE RESPS MUST (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: BE USED. WARN EMPLOYEES (& CUSTOMER USERS IN CASE OF
RESALE) BY POSTING & OTHER MEANS OF HAZ & OSHA PRECS (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: TO BE USED. PROVIDE TRAINING FOR EMPLOYEES ABOUT
OSHA PRECS. SEE ALSO ASTM STD PRACTICE E1132.86, "STD (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: PRACTICE FOR HLTH REQS RELATING TO OCCUP EXPOS TO
QUARTZ DUST." ALSO SEE MOST RECENT STDS OF ANSI Z.88.2 (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: & MSHA (30 CFR PART 56).
RTECS #:9999999ZZ
Ingred Name:RESP PROT: QUARTER MASK RESP. FUME RESP OR HIGH EFFICIENCY
PARTICULATE FILTER RESP. APPRVD SUPPLIED AIR RESP. (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: SCBA. 50 X PEL OR LESS: HIGH EFFICIENCY PARTICULATE
FILTER RESP W/FULL FACEPIECE. SUPPLIED AIR RESP (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: W/FULL FACEPIECE, HELMET OR HOOD. APPRVD SCBA
W/FULL FACEPIECE. 500 X PEL OR LESS: POWERED AIR (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: PURIFYING RESP W/HIGH EFFICIENCY PARTICULATE
FILTER. APPRVD TYPE C SUPPLIED AIR RESP OPERATED IN PRESS (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: DEMAND OR OTHER POS PRESS OR CONTINUOUS FLOW MODE.
GREATER THAN 500 X PEL OR ENTRY OPERATED IN PRESS & (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: ESCAPE FROM UNKNOWN CONCS: SCBA W/FULL FACEPIECE
DEMAND OR OTHER POS PRESS MODE. COMBINATION RESP WHICH (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17: INCLUDES TYPE C SUPPLIED AIR RESP W/FULL FACEPIECE
OPERATED IN PRESS DEMAND OR OTHER POS PRESS (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: CONTINUOUS FLOW MODE & AUXILIARY SCBA OPERATED IN
PRESS DEMAND OR OTHER POS PRESS MODE. ABRASIVE (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19: BLASTING: TYPE CE, SUPPLIED AIR RESP W/FULL
FACEPIECE, HOOD OR HELMET OPERATED IN POS PRESS MODE. (SEE (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20: 29 CFR 1910.94(A)). SEE ALSO ANSI STD Z88.2-1980
"PRACTICES FOR RESP PROT" & STD Z9.4-1984 "VENT & (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21: SAFE PRACTICES OF ABRASIVE BLASTING OPERATIONS."
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:PROLONGED EXPOSURE TO RESPIRABLE
SILICA MAY CAUSE DIMINISHED LUNG CAPACITY WITH SHORTNESS OF BREATH
DURING PHYSICAL EXERTION AND CAUSE UNDUE BREATHLESSNESS, WHEEZING,
COUGH AND SPUTUM PRODUCTION. EXCE SSIVE INHALATION OF DUST MAY
RESULT IN RESPIRATORY DISEASE INCLUDING SILICOSIS, PNEUMOCONIOSIS
AND (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ: IARC
MONOGRAPHS, SUPP, VOL 7, PG 341, 1987:GROUP 2A. NTP 7TH ANNUAL
REPORT ON (SUPDAT)
Effects of Overexposure:HLTH HAZ: PULMONARY FIBROSIS. ACUTE OR RAPIDLY
DEVELOPING SILICOSIS MAY OCCUR IN A SHORT PERIOD OF TIME IN HEAVY
EXPOSURE IN CERTAIN OCCUPATIONS SUCH AS SANDBLASTERS. SILICOSIS IS
A FORM OF DISABLING PULMONARY FIBROSIS WHICH CAN BE PROGRESSIVE
AND MAY LEAD TO DEATH. BE SURE TO MAINTAIN CURRENT PHYSICALS.
Medical Cond Aggravated by Exposure:INDIVIDUALS W/PULM OR RESP DISEASE
SUCH AS ASTHMA, BRONCHITIS & EMPHYSEMA SHOULD AVOID PRLNGD EXPOS OF
SILICA DUST. PULM FUNC MAY BE REDUCED BY INHAL OF RESPIRABLE
CRYSTALLINE SILICA. ALSO (SUPDAT)
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMEDIATELY . SKIN: FLUSH W/COPIOUS AMOUNTS
OF WATER. CALL MD . EYES: WASH EYES WITH LARGE AMOUNTS OF WATER,
OBTAIN MEDICAL ATTENTION IF IRRITATION PERSISTS. INHAL: REMOVE TO
AREA OF FRESH AIR; GIVE OXYGEN OR CPR IF NECESSARY. SEEK MEDICAL
ATTENTION FOR TREATMENT, OBSERVATION AND SUPPORT AS NEEDED.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE . WILL NOT
BURN.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CRYSTALLINE SILICA IS NEITHER A FIRE NOR
AN EXPLOSION HAZARD. SAND MAY BE USED TO SMOTHER AND PUT OUT CLASS
A AND B FIRES.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP BY DUSTLESS METHODS (WATER OR
VACUUM); PUT IN CLOSED CONTAINER (NOTE: DO NOT USE AIR OR DRY
SWEEP). USE APPROVED NIOSH RESPIRATORS FOR DUST 929 CFR 1910.134).
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID SPILLAGE. USE DUSTLESS SYSTEMS
FOR HANDLING & EMPLOY ENGINEERING CONTROLS TO REDUCE CONCENTRATION
OF AIRBORNE DUST. (EXAMPLE:APPRVD BAG HOUSE).
Other Precautions:POST WARNING SIGNS TO KEEP ALL PERSONS ALERTED TO
DUSTY AREAS. USE DUSTLESS SYS FOR HNDLG, STOR & CLEAN UP SO
AIRBORNE DUST DOES NOT EXCEED PEL. USE ADEQ VENT & DUST COLLECTION.
PRACTICE GOOD HOUSEKEE PING. DO NOT PERMIT DUST TO (ING 4)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOWING SPECIFIES TYPES OF RESPS WHICH MAY
PROVIDE RESP PROT FOR CRYSTALLINE SILICA. ONLY NIOSH APPRVD EQUIP
SHOULD BE USED (SEE 29 CFR 1910.134): 5 X PEL OR LESS: DUST RESP.
10 X PEL OR LESS: DUST RESP EXCEPT SINGLE USE OR (ING 12)
Ventilation:LOCAL EXHAUST - WHEN POSSIBLE TO MEET PEL STANDARDS. MECH:
APPROVED BAG-HOUSE. SPECIAL: APPROVED WET SCRUBBER.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER . USE
NIOSH APPROVED DUST RESPIRATORS.
Work Hygienic Practices:AVOID CREATING AND BREATHING DUST.
Supplemental Safety and Health
MATLS TO AVOID: AGENTS, FLUORINE, CHLORINE TRIFLUORIDE, MANGANESE
TRIOXIDE & OXYGEN DIFLUORIDE MAY CAUSE FIRES. EXPLAN OF CARCIN:
CARCINS, 1994:ANTIC TO BE CARCIN. MED CNDTNS: LUNG SCARRING
PRODUCED B Y SUCH INHAL MAY LEAD TO PROGRESSIVE MASSIVE FIBROSIS OF
LUNG WHICH MAY AGGRAVATE OTHER PULM CNDTNS & DISEASES (ING 2)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:4046F,2230C
Vapor Pres:NONE
Vapor Density:NONE
Spec Gravity:2.85 (H*2O=1)
Evaporation Rate & Reference:NONE
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE OR TAN SAND, GRANULAR; NO ODOR OR TASTE.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SILICA WILL DISSOLVE IN HYDROFLUORIC ACID & PRDCE CORR GAS - SILICON
TETRA FLUORIDE. CNTCT W/POWERFUL OXIDIZING (SUPDAT)
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:IF UNCONTAMINATED, DISPOSE AS AN INERT,
NON-METALLIC MINERAL. IF CONTAMINATED USE APPROPRIATE METHOD IN
LIGHT OF CONTAMINATION IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
LAWS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ADRUCIL INJECTION; FLUOROURACIL,USP
Preparer's Name:A. DANALS
CAGE:58750
CAGE:58750
============= Composition/Information on Ingredients =============
Ingred Name:FLUOROURACIL (SARA 302)
CAS:51-21-8
RTECS #:YR0350000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:UNDETERMINED.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THE EFFECTS OF OVEREXPOSURE HAVE NOT
BEEN ESTABLIHED BUT IT'S LIKELY THAT AN EXAGGERATION OF KNOWN TOXIC
EFFECTS MAY OCCUR THE MOST PROMINENT OF WHICH ARE MYELOSUPPRESSIVE
& MUCOUS MEMBRANE TOXICITY. ACUTE:BY INJECTION -NAUSEA, VOMITING,
MYELOSUPPRESSIVE. CHRONIC:UNDETERMINED.
Explanation of Carcinogenicity:PER MSDS:CHEM LISTED AS CARCINOGEN/POT
CARCINOGEN:NTP/IARC/OSHA:NO.
Effects of Overexposure:MYELOSUPPRESSIVE & MUCOUS MEMBRANE TOXICITY.
NAUSEA, VOMITING.
Medical Cond Aggravated by Exposure:UNDETERMINED.
======================= First Aid Measures =======================
First Aid:INHAL:SEEK MED ATTN. EYE:RINSE W/COPIOUS AMTS OF WATER.
IRRIGATE IMMED W/WATER OR SALINE. SKIN:WASH THOROUHGLY W/SOAP/WATER
& RINSE W/COPIOUS AMTS OF WATER. INGEST:SEEK MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:NA
Autoignition Temp:Autoignition Temp Text:NA
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:NONE SPECIFIED BY MANUFACTURER.
Fire Fighting Procedures:EVACUATE PERSONNEL TO SAFE AREA. FIREFIGHERS
SHOULD USE SELF-CONTAINED BREATHING APPARATUS & PORTECTIVE EQPMT.
Unusual Fire/Explosion Hazard:WHEN HEATED TO DECOMPOSITION MATL EMITS
TOXIC FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:DEACTIVATE W/DILUTE BLEACH SOLUITON. RINSE
WELL W/WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:ADRUCIL IS POTENT ANTI-CANCER
DRUG.CAUTION IN HDNGL/USE MUST BE EXERCISED. IF ADRUCIL SOLN
CONTACTS SKIN/MUCOUSAE IMMED WASH THOROUHGHLY W/SOAP/WATER.
Other Precautions:STORE 15-30C PROTECT FROM LIGHT. SEE PRODUCT INSERT
FOR FURTHER INFORMATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPORVED RESPIRATOR FOR TOXIC MISTS OR
AEROSOLS.
Ventilation:LOCAL EXHASUAT/MECHANICAL (GENERAL):ADEQUATE/VERTICAL
LAMINAR FLOW HOOD. HEPA FILGER VENTED TO OUTSIDE AIR.
Other Protective Equipment:LONG SLEEVED IMPERMEABLE, DISPOSABLE GOWN
W/ELASTIC CUFFS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MSDS DATED 11-8-85.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:SIMILAR H2O
Melt/Freeze Pt:M.P/F.P Text:NP
Decomp Temp:Decomp Text:NP
Spec Gravity:1.0297
pH:NP
Viscosity:NP
Evaporation Rate & Reference:UNDETERMINED
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR TO FAINTLY YELLOW AQUEOUS YELLOW SOLUTION; NO
ODOR.
Percent Volatiles by Volume:95
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
UNDETERMINNED.
Stability Condition to Avoid:UNDETERMINED.
Hazardous Decomposition Products:FLUORINE & NXO GASES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DEACTIVATED W/DILUTE BLEACH SOLN.DISPOSE OF IN
ACCORDANCE WITH YOUR PROCEDURE FOR HAZ WASTE DISPOSAL TO MEET
LOC/STTE/FED REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:KRYLON INT/EXT ENAMEL (SEE SUPPLEMENTAL)
Preparer's Name:NOT PROVIDED
CAGE:TO534
Contract Num:MDA414-00-P-1788
CAGE:33089
Contract Num:MDA414-00-T-0001-0424
CAGE:33089
CAGE:TO534
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE
CAS:67-64-1
RTECS #:AL3150000
Minumum % Wt:30.
Maxumum % Wt:50.
OSHA PEL:2400 MG/M3;1000 PPM
ACGIH TLV:1780 MG/M3;750 PPM
ACGIH STEL:2380 MG/M3;1000 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Minumum % Wt:10.
Maxumum % Wt:30.
OSHA PEL:1800 MG/M3;1000 PPM
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:200 PPM
ACGIH TLV:188 MG/M3;50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE
CAS:1330-20-7
RTECS #:ZE2100000
Minumum % Wt:10.
Maxumum % Wt:30.
ACGIH TLV:434 MG/M3;100 PPM
ACGIH STEL:651 MG/M3;150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:1-BUTANOL
CAS:71-36-3
RTECS #:EO1400000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:300 MG/M3;100 PPM
ACGIH STEL:C152 MG/M3;C50 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE
CAS:78-93-3
RTECS #:EL6475000
Minumum % Wt:5.
Maxumum % Wt:10.
OSHA PEL:590 MG/M3;200 PPM
ACGIH TLV:590 MG/M3;200 PPM
ACGIH STEL:885 MG/M3;300 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ISOBUTYL KETONE
CAS:108-10-1
RTECS #:SA9275000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:410 MG/M3;100 PPM
ACGIH TLV:205 MG/M3;50 PPM
ACGIH STEL:307 MG/M3;75 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-PROPANOL, 1-METHOXY-, ACETATE
CAS:108-65-6
RTECS #:AI8925000
Minumum % Wt:5.
Maxumum % Wt:10.
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN ABSORPTION: NO HAZARDS KNOWN TO
BORDEN. INGESTION: NOT EXPECTED TO BE HARMFUL UNDER NORMAL
CONDITIONS OF USE. IF ACCIDENTALLY SWALLOWED, BURNS OR IRRITATION
TO MUCOUS MEMBRANES, ESOPHAGUS OR GI T RACT CAN RESULT. INHALATION:
MAY BE HARMFUL IF INHALED. LIQUID OR VAPOR CAN CAUSE IRRITATION OF
NOSE, THROAT & LUNGS. CAN CAUSE CENTRAL NERVOUS SYSTEM DEPRESSION.
SKIN: CAUSES IRRITATION. EYES: CAUSES IRRITATION.
Explanation of Carcinogenicity:AS OF THE DATE OF ISSUANCE OF THIS
DOCUMENT, THIS MATERIAL HAS NOT BEEN LISTED BY NTP, IARC OR OSHA AS
A CARCINOGEN.
Effects of Overexposure:ACETONE: SYMPTOMS MAY INCLUDE HEADACHE,
DIZZINESS NAUSEA, VOMITING, UNCONSCIOUSNESS AND EVEN ASPHYXIATION.
1-BUTANOL: SIGNS & SYMPTOMS MAY INCLUDE HEADACHE, DIZZINESS,
NAUSEA, VOMITING, UNCONSCIOUSNES S & EVEN ASPHYXIATION. PROPANE:
CYANOSIS, RESPIRATORY DISTRESS, HEADACHE, DIZZINESS, DROWSINESS,
UNCONSCIOUSNESS & ASPHYXIATION. METHYL ETHYL KETONE: MAY INCLUDE
HEADACHE, DIZZINESS, NAUSEA, VOMITING, UNCONSCIOUSNESS &
ASPHYXIATION. METHYL ISOBUTYL KETONE: MAY INCLUDE HEADACHE,
DIZZINESS, NAUSEA, VOMITING, UNCONSCIOUSNESS & EVEN ASPHYXIATION.
TOLUENE: MAY INCLUDE HEADACHE, DIZZINESS, NAUSEA, VOMIT ING,
UNCONSCIOUSNESS & ASPHYXIATION.
======================= First Aid Measures =======================
First Aid:INGESTION: DILUTE BY DRINKING LARGE QUANTITIES OF WATER.
IMMEDIATELY CONTACT POISON CONTROL CENTER OR HOSPITAL EMERGENCY
ROOM FOR ADDITIONAL TREATMENT. INHALATION: REMOVE TO FRESH AIR. IF
NOT BREATHIN G, GIVE ARTIFICIAL RESPIRATION, PREFERABLY
MOUTH-TO-MOUTH. SKIN: FLUSH WITH PLENTY OF WATER. REMOVE
CONTAMINATED CLOTHING. CALL A PHYSICIAN IF IRRITATION PERSISTS.
EYES: IMMEDIATELY FLUSH EYES WITH PL ENTY OF WATER FOR AT LEAST 15
MINUTES. EYELIDS SHOULD BE HELD APART DURINGIRRIGATION TO INSURE
WATER CONTACT WITH ENTIRE SURFACE OF EYES & LIDS. CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:AEROSOL CAN
Extinguishing Media:IN CASE OF FIRE USE DRY CHEMICAL, FOAM OR CO2.
WATER MAY BE INEEEFCTIVE BUT SHOULD BE USED TO KEEP FIRE-EXPOSED
CONTAINERS COOL.
Fire Fighting Procedures:DO NOT INCINERATE (BURN) CONTAINER. AVOID
HEAT. KEEP CONTAINER BELOW 120F. HIGH TEMPERATURES MAY CAUSE
BURSTING. DO NOT PLACE CONTAINER ON RADIATOR, STOVE, IN DIRECT
SUNLIGHT OR NEAR OTHER HEAT SOURCE . DO NOT PUNCTURE CONTAINER.
Unusual Fire/Explosion Hazard:CONTENTS UNDER PRESSURE. WILL DISCHARGE.
AVOID OPEN FLAMES, SPARKS, PILOT LIGHTS. DO NOT SMOKE. VAPOR MAY
IGNITE EXPLOSIVELY. SPRAY MISTS OR VAPOR EVAPORATING FROM A
DEFROSTED FILM IS HEAVIER THAN AIR& MAY SETTLE IN LOW PLACES OR
TRAVEL OUTWARD TO A SOURCE OF OGNITION & FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITIOIN SOURCES. SOAK UP WITH
ABSORBENT MATERIAL & REMOVE TO A CHEMICAL DISPOSAL AREA. PREVENT
ENTRY INTO BODIES OF WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE-DO NOT STORE AT TEMPERATURES
OVER 120F. HANDLING-AVOID BREATHING VAPOR OR MIST. USE WITH
ADEQUATE VENTILATION. AVOID CONTACT WITH SKIN. AVOID CONTACT WITH
EYES.
Other Precautions:HANDLE IN ACCORDANCE WITH GOOD INDUSTRIAL HYGIENE &
SAFETY PRACTICES WHICH INCLUDE AVOIDING UNNECESSARY EXPOSURE &
REMOVAL FROM EYES, SKIN & CLOTHING. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE AIR CONTAMINANTS CAN EXCEED CRITERIA, USE
NIOSH-MSHA APPROVED RESPIRATORY PROTECTION EQUIPMENT. RESPIRATORS
SHOULD BE SELECTED BASED ON THE FORM & CONCENTRATION OF
CONTAMINANTS IN AIR IN ACCORDA NCE WITH OSHA 29 CFR 1910.134 OR
OTHER APPLICABLE STANDRADS OR GUIDELINES.
Ventilation:LOCAL EXHAUST, ENCLOSED SYSTEM DESIGN, REMOTE CONTROL ALONG
WITH PPE ARE OPTIONS
CONTACT.
Supplemental Safety and Health
NASCO: CONTRACTOR'S PART NUMBER: 97-14406(F) PAINT, KRYLON 12 OZ CAN
SPRAY ENAMEL ULTRA FLAT BLACK.
================== Physical/Chemical Properties ==================
HCC:V3
Solubility in Water:SLIGHT
Appearance and Odor:NOT PROVIDED. PRODUCT IN AEROSOL CAN
Percent Volatiles by Volume:87-89 BY VOL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:OXIDES OF CARBON
Conditions to Avoid Polymerization:WIIL NOT OCCUR.
===================== Ecological Information =====================
Ecological:NOT PROVIDED
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE &
FEDERAL REGULATIONS. EMPTY CONTAINER MAY CONTAIN EXPLOSIVE VAPORS.
DO NOT CUT, PUNCTURE OR WELD NEARBY. INCINERATION WILL CAUSE
CONTAINER TO BURST VIOLENTL Y.
=================== MSDS Transport Information ===================
Transport Information:DOT CLASSIFICATION: ORM-D CONSUMER COMMODITY.
===================== Regulatory Information =====================
SARA Title III Information:SECTION 313: ACETONE, 36.71%; N-BITYL
ALCOHOL, 1.00%; METHYL ETHYL ALCOHOL, 8.34%; METHYL ISOBURTL
KETONE, 1.00%; 2-PROPANOL 1-METHOXY, ACETATE, 7.51%; TOLUENE, 1.63;
XYLENE (MIXED ISOMERS), 10.66%.
Federal Regulatory Information:THIS MATERIAL IS A "HEALTH HAZARD"
AND/OR "PHYSICAL HAZARD" AS DETERMINED WHEN REVIEWED ACCORDING TO
THE REQUIREMENTS OF THE OCCUPATIONAL SAFETY AND HEALTH
ADMINISTRATION 29 CFR PART 1910.1200 "HAZARD COMMUNICATIO"N
STANDARD.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:9053 FREON 113 PHOTREX REAGENT
CAGE:FO887
CAGE:FO887
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:1,1,2-TRICHLORO-1,2,2-TRIFLUOROETHANE (FREON 113) (SARA
III)
CAS:76-13-1
RTECS #:KJ4000000
Fraction by Wt: 90-100%
Other REC Limits:1000 PPM
OSHA PEL:1000PPM/1250STEL
ACGIH TLV:1000PPM/1250STEL9192
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 43 G/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: IRRITATION. INHALATION:
NARCOSIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN/EYES: IRRITATION. INHALATION: NARCOSIS.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS.
INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR PROPER PROTECTIVE
EQUIPMENT & SELF-CONTAINED BREATHING APPARATUS W/FULL FACEPIECE
OPERATED IN POSITIVE PRESSURE MODE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. STOP LEAK, SAFELY.
USE WATER SPRAY TO REDUCE VAPORS. TAKE UP W/SAND OR OTHER
NON-COMBUSTIBLE ABSORBENT MATERIAL & PLACE INTO CONTAINER FOR LATER
DISPOSAL. FLUSH SPILL AREA W /WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED.
SUITABLE FOR ANY GENERAL CHEMICAL STORAGE AREA.
Other Precautions:AVOID CONTACT W/EYES, SKIN, & CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF >TLV, USE A SELF-CONTAINED BREATHING
APPARATUS.
Ventilation:USE MECHANICAL (GENERAL)/LOCAL EXHAUST VENTILATION TO KEEP
<TLV.
Other Protective Equipment:LAB COAT, UNIFORM
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:118F
Melt/Freeze Pt:M.P/F.P Text:-31F
Vapor Pres:285
Vapor Density:6.4
Spec Gravity:1.57
Evaporation Rate & Reference:(BU AC = 1): 0.45
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID W/SLIGHT ETHERAL ODOR.
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALI METALS, CHEMICALLY ACTIVE METALS
Stability Condition to Avoid:FLAME, HEAT, OR OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:HALOGEN ACIDS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
Product ID:MIL-C-85285B, 11136, TYPE I, 03R064
Kit Part:Y
CAGE:33461
CAGE:33461
============= Composition/Information on Ingredients =============
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL 3-ETHOXYPROPIONATE (SARA 313) (VAPOR PRESSURE .7 MM
HG)
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
Ingred Name:ANTISETTLING AGENT (VAPOR PRESSURE 0 MM HG)
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS) (SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ANTI-FLOAT AGENT (VAPOR PRESSURE 0 MM HG)
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
Ingred Name:FLOW AGENT (VAPOR PRESSURE 0 MM HG)
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
Ingred Name:METHYL N-AMYL KETONE
CAS:110-43-0
RTECS #:MJ5075000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9192
Ingred Name:ANTI MAR AGENT (VAPOR PRESSURE 0 MM HG)
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
Ingred Name:ETHYL BENZENE (SARA III)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: <0.1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/125 STEL
ACGIH TLV:100 PPM/125STEL 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:FLOW AGENT (VAPOR PRESSURE 0 MM HG)
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
Ingred Name:PMGE ACETATE (VAPOR PRESSURE 3.8 MM HG)
CAS:108-65-6
RTECS #:AI8925000
Fraction by Wt: <1%
Other REC Limits:RECOMM TLV: 100 PPM
Ingred Name:DIBUTYLTIN DILAURATE (VAPOR PRESSURE .2 MM HG)
CAS:77-58-7
RTECS #:WH7000000
Fraction by Wt: <0.1%
Other REC Limits:NONE SPECIFIED
ACGIH TLV:.1MG/M3.2MG/M3 STEL
Ingred Name:2-4 PENTANEDIONE (VAPOR PRESSURE 7 MM HG)
CAS:123-54-6
RTECS #:SA1925000
Fraction by Wt: <5%
Other REC Limits:(U C) TLV:20 PPM TWA
Ingred Name:VOC: 330 G/L
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: VAPORS IRRITATING TO EYES/NOSE/
THROAT. INHALATION: IRRITATION, ACUTE NERVOUS SYSTEM DEPRESSION.
CHRONIC: PROLONGED CONTACT WILL CAUSE DEFATTING ACTION, SKIN
SENSITIZATION, ASTHMA OR OTHER ALLE RGIC RESPONSES MAY DEVELOP.
INGESTION: IRRITATION. ASP
Effects of Overexposure:INHAL: DIFFICULT BREATHING, HEADACHE,
DIZZINESS, STAGGERING GAIT, CONFUSION, UNCONSCIOUSNESS, COMA. SKIN:
IRRIT (SWELLING/REDNESS/RASH). EYES: REDNESS, TEARING, SWELLING
W/STINGING. SKIN: PROLONGED/RE PEATED--MODERATE IRRIT, DRYING, SKIN
CRACKING. INGEST:Medical Cond Aggravated by Exposure:ASTHMA AND ANY
OTHER RESPIRATORY DISORDERS. SKIN ALLERGIES, ECZEMA, AND
DERMATITIS.
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE TO FRESH AIR. RESTORE BREATHING. ASTHMATIC
TYPE SYMPTOMS MAY DEVELOP (IMMED/DELAYED BY SEVERAL HRS). GET MED
AID. SKIN: REMOVE CONTAM CLOTHING. WASH AREA W/SOAP & WATER. WASH
CONTAM C LOTHING BEFORE REUSE. EYES: FLUSH WITH LUKEWARM WATER
===================== Fire Fighting Measures =====================
Flash Point:45.0F,7.2C
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE
ALL SOURCES OF IGNITION (FLAME, SPARK SOURCES, HOT SURFACES).
VENTILATE AREA. CONTAIN AND REMOVE WITH INERT ABSORBENT AND
NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN BLDG IN COMPLIANCE W/OSHA
1910.106. AVOID HIGH TEMP, IGNITION SOURCES. STORE IN TIGHTLY
CLOSED CONTAINERS. STORE IN WELL VENT AREAS.
Other Precautions:KEEP CNTNRS CLOSED TIGHT/UPRIGHT (PREVENT LEAKAGE).
NO PROLONGED BREATHING--VAPORS/SPRAY MISTS. NO CONTACT W/SKIN/EYES.
DON'T TAKE INTERNALLY. DON'T HANDLE UNTIL THE SAFETY PRECAUTIONS
HAVE BEEN READ/ UNDERSTOOD. SMOKE ONLY IN SMOKING AREAS
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE ORGANIC VAPOR RESPIRATOR (AIR
PURIFYING/FRESH AIR SUPP). OBSERVE OSHA REGULATIONS (RESPIRATOR
USE). PROVIDE VENT TO KEEP EXPOS LEVELS BELOW OSHA LIMITS. IF BELOW
TLV, OTHER NIOSH/MSHA APPROVED RSP RTR MAY BE USED.
Ventilation:EXHAUST VENT SUFFICIENT TO KEEP AIRBORNE CONC (MIST/VAPOR)
BELOW TLV'S MUST BE USED. REMOVE ALL IGNITION SOURCE.
Other Protective Equipment:FACE SHIELDS. THE USE OF LONG SLEEVE AND
LONG LEG CLOTHING IS RECOMMENDED.
Work Hygienic Practices:REMOVE AND WASH CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS BEFORE EATING, SMOKING OR USING THE WASHROOM.
Supplemental Safety and Health
================= Stability and Reactivity Data =================
Hazardous Decomposition Products:BY HIGH HEAT/TEMPERATURE: CARBON
MONOXIDE, CARBON DIOXIDE, AND OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MUST BE DISPOSED IN ACCORD W/FEDERAL,
STATE & LOCAL ENVIRONMENTAL CONTROL REGULATIONS. EMPTY CONTAINERS
MUST BE HANDLED W/CARE (PRODUCT RESIDUE/FLAMMABLE VAPOR). DON'T
INCINERATE CLOSED CNTNRS. EPA HAZARDOUS WASTE #: D001, F003, F005.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-C-83286, 17043, 03Y055
Kit Part:Y
CAGE:DO188
CAGE:33461
CAGE:DO188
============= Composition/Information on Ingredients =============
Ingred Name:2-ETHOXYETHYL ACETATE (CELLOSOLVE ACETATE) (EGEEA)
CAS:111-15-9
RTECS #:KK8225000
Fraction by Wt: 30%
Other REC Limits:NONE SPECIFIED
OSHA PEL:S,100 PPM
ACGIH TLV:S, 5 PPM; 9192
Ingred Name:*IN TEST ANIMALS, ALSO THERE MAY BE LIVER AND/OR KIDNEY
EFFECTS. MFR RECOMMENDS AVOIDING ALL SKIN CONTACT, AND A 5 PPM**
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
Ingred Name:**(8 HOUR TWA) PERSONAL EXPOSURE LIMIT.
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
Ingred Name:ETHYL ACETATE (SARA III)
CAS:141-78-6
RTECS #:AH5425000
Fraction by Wt: 15%
Other REC Limits:NONE SPECIFIED
OSHA PEL:400 PPM
ACGIH TLV:400 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 15%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PMGE ACETATE (VAPOR PRESSURE 3.8 MM HG)
CAS:108-65-6
RTECS #:AI8925000
Fraction by Wt: <0.1%
Other REC Limits:TLV IS 100 PPM
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
Ingred Name:DIBUTYLTIN DILAURATE (VAPOR PRESSURE .2 MM HG)
CAS:77-58-7
RTECS #:WH7000000
Fraction by Wt: <0.1%
Other REC Limits:NONE SPECIFIED
ACGIH TLV:.1MG/M3;.2MG/M3 STEL
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: VAPORS IRRITATING:
EYES/NOSE/THROAT. INHALATION MAY CAUSE HEADACHE/DIFFICULT
BREATHING/UNCONSCIOUSNESS. CHRONIC: PROLINGED CONTACT WILL CAUSE
DRYING AND CRACKING OF THE SKIN DUE TO DEFATTING AC TION. SKIN
SENSITIZATION, ASTHMA OR OTHER ALLERGIC RESPONSES MAY DEVELOP.
Effects of Overexposure:INHALE: IRRITATE-RSPRTRY TRACT/ACUTE NERVOUS
SYSTEM DEPRESSION PROGRESS:
HEADACHE/DIZZINESS/STAGGERING/CONFUSION/UNCONSCIOUSNESS/COMA. SKIN:
IRRITATE-SWELL/REDNESS/RASH/DRY/DEFAT/CRACK. EYE: IRRITATE/
TEAR/REDNESS/SWELL/STING. INGEST: IRRITATE/CORROSIVE TO MOUTH/STMCH
TISSUE/DIGEST TRACT. CHEM PNEUMONITIS.
Medical Cond Aggravated by Exposure:ASTHMA AND ANY OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA, AND DERMATITIS.
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE TO RISK-FREE AREA. RESTORE BREATHING.
ASTHMA-LIKE SYMPTOMS (IMMED/DELAYED BY HRS). MEDICAL ATTENTION.
SKIN: REMOVE CONTAMINATED CLOTHING. WASH AREAS W/SOAP/WATER. WASH
CONTAMINATED CL OTHING BEFORE REUSE. EYES: FLUSH W/CLEAN LUKEWARM
WATER (LOW PRESSURE)-15 MIN, LIFT LIDS. MEDICAL ATTENTION.
INGESTION: DO NOT INDUCE VOMITING. NOTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:24.0F,-4.4C
Lower Limits:1.5
Extinguishing Media:FOAM, ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL,
WATER FOG.
Fire Fighting Procedures:FULL GEAR W/SELF-CONTAINED BREATHING APPARATUS
ON FIRE FIGHTERS. WATER USED TO COOL CLOSED CONTAINERS TO PREVENT
PRESSURE BUILD-UP/AUTO IGNITION/EXPLOSION.
Unusual Fire/Explosion Hazard:CNTNRS CLSD. NO HEAT/SPARKS/ELECTRICAL
EQUIPMENT/OPEN FLAME. CLSD CNTNRS MAY EXPLODE W/EXTREME HEAT.
APPLIC TO HOT SURFACES--SPECIAL PRECAUTIONS. DECOMP HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAR AREA. REMOVE ALL SOURCES OF IGNITION:
FLAME/SPARK SOURCES/HOT SURFACES. VENTILATE AREA. CONTAIN AND
REMOVE WITH INERT ABSORBANT AND NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:BUILDINGS DESIGNED TO COMPLY WITH OSHA
1910.106. NO STORING NEAR HIGH TEMPERATURES, FIRE, OPEN FLAMES,
SPARK SOURCES. WELL VENTILATED AREAS.
Other Precautions:CONTAINERS TIGHT/UPRIGHT-NO LEAKAGE. NO PROLONGED
BREATHING VAPORS/SPRAY MISTS--MAY CAUSE ALLERGIC REACTION. NO
CONTACT SKIN/EYES. NO INGESTION. UNDERSTAND MFR'S SAFETY
PRECAUTIONS. SUBJECT TO REPORTI NG REQUIREMENTS OF SECTION 313 OF
THE *
============= Exposure Controls/Personal Protection =============
Respiratory Protection:APPROVED RESPIRATOR RECOMMENDED FOR ORGANIC
VAPOR ENVIRONMENT (AIR PURIFYING OR FRESH AIR SUPPLIED). OBSERVE
OSHA REGULATIONS FOR RESPIRATOR USE. VENTILATION TO KEEP EXPOSURE
LEVELS BELOW OSHA LIMITS.
Ventilation:VENTILATION SUFFICIENT TO KEEP AIRBORNE CONCENTRATIONS OF
SOLVENT VAPORS OR MISTS BELOW TLV'S. NO IGNITION SOURCES.
Other Protective Equipment:FACE SHEILDS. LONG SLEEVES/LONG LEG CLOTHING
IS RECOMMENDED. REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
WASHROOM. SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
*SUPERFUND AMENDMENTS REAUTHORIZATION ACT OF 1986 & 40 CFR 372.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:169 TO 338F
Vapor Density:>AIR
Spec Gravity:1.01
Viscosity:*
Evaporation Rate & Reference:2.52 (X N BUTYL ACETATE)
Appearance and Odor:CLEAR LIQUID WITH SOLVENT ODOR
Percent Volatiles by Volume:63.2
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMERATURES, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:BY HIGH HEAT/TEMPERATURE: CARBON
MONOXIDE, CARBON DIOXIDE, AND OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS. DUE TO PRODUCT RESIDUE AND FLAMMABLE VAPOR DO NOT
INCINERATE CLOSED CONTAINERS/HANDLE WITH CARE. EPA HAZARDOUS WASTE
NUMBER/CODE: D001, F003, F 005.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:GLYCEROL DEHYDROGENASE
CAGE:GO448
CAGE:GO448
============= Composition/Information on Ingredients =============
Ingred Name:GLYCEROL DEHYDROGEASE
CAS:9028-14-2
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SKIN, EYE/RESPIRATORY TRACT
IRRITATION UPON CONTACT. ALLERGIC REACTIONS IN CERTAIN SENSITIVE
INDIVIDUALS MAY DEVELOP.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, ALLERGIC REACTIONS.
Medical Cond Aggravated by Exposure:ALLERGIES, ASTHMA.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES/SKIN: WASH THOROUGHLY
W/WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID PHYSICAL CONTACT & DUST DURING REMOVAL.
USE NORMAL CLEAN-UP PROCEDURES & WASH THOROUGHLY W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR DUST MASK.
Ventilation:LOCAL EXHAUST: AS REQUIRED. MECHANICAL (GENERAL): VENT FAN.
Supplemental Safety and Health
SOLUBILITY IN WATER: POWDERS-APPRECIABLE. LIQUIDS-MISCIBLE.
================== Physical/Chemical Properties ==================
Solubility in Water:(SEE SUPP)
Appearance and Odor:POWDERS- WHITE TO TAN. LIQUIDS-WHITE TO BROWN. BOTH
HAVE TYPICAL ENZYME ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH IN SEWERAGE SYSTEM W/WATER IAW/FEDERAL,
STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RPCK-1A AROCLOR 1242 AT 100 UG/ML IN HEXANE
Kit Part:Y
CAGE:0MU35
CAGE:0MU35
============= Composition/Information on Ingredients =============
Ingred Name:HEXANE, N-HEXANE
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: 99.87%
Other REC Limits:50 PPM
OSHA PEL:1800 MG/CUM
ACGIH TLV:176 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CHLORODIPHENYL (42% CL), PCB, POLYCHLORINATED BIPHENYL,
AROCHLOR 1242 (SUSPECTED HUMAN CARCINOGEN BY IARC) * 94-3 *
CAS:53469-21-9
RTECS #:TQ1356000
Fraction by Wt: 0.015%
Other REC Limits:0.001 MG/CUM NIOSH
OSHA PEL:1 MG/CUM
ACGIH TLV:1 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 4250 MG/KG
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TOXIC; IRRITANT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:TOXIC; IRRITANT.
======================= First Aid Measures =======================
First Aid:EYE/SKIN: FLUSH W/COPIOUS AMOUNTS OF WATER. INHALATION:
REMOVE TO FRESH AIR. GIVE OXYGEN IF NECESSARY. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, DRY CHEMICAL POWDER/WATER SPRAY
================== Accidental Release Measures ==================
Spill Release Procedures:A LEAKING BOTTLE MAY BE PLACED IN A PLASTIC
BAG & NORMAL DISPOSAL PROCEDURES FOLLOWED. LIQUID SAMPLES MAY BE
ABSORBED ON VERMICULITE/SNAD.
======================Handling and Storage ======================
Handling and Storage Precautions:USE APPROPRIATE OSHA/MSHA APPROVED
SAFETY EQUIPMENT. KEEP TIGHTLY CLOSED & STORE IN A COOL, DRY PLACE.
Other Precautions:PREVENT CONTACT W/EYES & SKIN. MATERIAL SHOULD BE
USED BY THOSE PERSONS TRAINED IN THE SAFE HANDLING OF HAZARDOUS
CHEMICALS. ALL CHEMICALS SHOULD BE CONSIDERED HAZARDOUS, DIRECT
PHYSICAL CONTACT SHOUL D BE AVOIDED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE OSHA/MSMA APPROVED SAFETY EQUIPMENT
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING: LAB COAT,
RUBBER APRON.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Appearance and Odor:LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED W/AN
AFTERBURNER & SCRUBBER. OBSERVE ALL FEDERAL, STATE & LOCAL LAWS
CONCERNING DISPOSAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CERAMCO STAIN SET, 485005
CAGE:79717
CAGE:79717
============= Composition/Information on Ingredients =============
Ingred Name:1,2-PROPANEDIOL; (PROPYLENE GLYCOL)
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: 74.89%
Ingred Name:DISTILLED WATER
Fraction by Wt: 17.7%
Ingred Name:AMMONIUM COMPOUND (CASEINATE)
Fraction by Wt: 7.2%
Ingred Name:SUPP DATA: NYSTAGMUS, LYMPHOCYTOSIS AND UNCONSCIOUSNESS.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:IF BRTHG HAS STOPPED, PERFORM ARTF RESP.
KEEP PERSON WARM AND AT REST. GET MED ATTN IMMED. INGEST:(ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:IF VICTIM IS CONSCIOUS, IMMED GIVE 2-4 GLASSES OF
H*2O & INDUCE VOMIT BY TOUCHING FINGER TO BACK OF THROAT.(ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: GET MEDICAL ATTENTION IMMEDIATELY.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITANT. ACUTE: DIRECT CONT MAY
CAUSE REDNESS/IRRIT. SKIN: IRRITANT. ACUTE: IRRIT/DRYNESS MAY OCCUR
FROM DEFATTING ACTION OF LIQ. INHAL: IRRITANT. ACUTE: INHAL OF
SUBSTANCE MAY CAUSE RESP/THROA T IRRIT. HIGH VAP CONC MAY CAUSE CNS
DEPRESS W/HDCH, DIZZ/DROW. INGEST: ACUTE: INITIAL SYMP IN MASSIVE
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: DOSES (OVER 100ML IN SINGLE DOSE) ARE
THOSE OF ALCOHOL INTOXICATION. SYMP SOON PROGRESS TO VOMIT,
CYANOSIS, HDCH, TACHYPNEA, TACHYCARDIA, HYPOTENSION, PULM EDEMA,
MUSCLE TENDERNESS, STUPOR,ANURIA, PROSTRATION & UNCON
W/CONVULSIONS. HYPOGLYCEMIA MAY OCCUR. DEATH MAY OCCUR W/IN FEW
HOURS FROM RESP (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: WASH EYES IMMED W/LRG AMTS OF H*2O, OCCASIONALLY
LIFTING UPPER/LOWER LIDS FOR AT LEAST 15 MIN, UNTIL NO EVIDENCE OF
CHEM REMAINS. IF REDNESS/IRRIT PERSISTS, GET MED ATTN. SKIN: REMOVE
CONTAM CLT HG & SHOES. WASH AFFECTED AREAS W/SOAP/MILD DETERGENT &
LRG AMTS OF H*2O UNTIL NO EVIDENCE OF CHEM REMAINS (APPROX. 15-20
MIN). GET MED ATTN. INHAL: REMOVE FROM EXPOS AREA TO FRESH AIR
IMMED.(ING 5)
===================== Fire Fighting Measures =====================
Flash Point:210F,99C
Lower Limits:2.6%
Upper Limits:12.5%
Extinguishing Media:WATER FOG, ALCOHOL FOAM, CARBON DIOXIDE, DRY
CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROT
EQUIP . NO ACUTE HAZ. MOVE CONTAINER FROM FIRE AREA IF POSSIBLE.
AVOID BREATHING VAPORS; KEEP UPWIND.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:SHUT OFF IGNITION SOURCES. STOP LEAK IF YOU
CAN DO IT WITHOUT RISK. FOR SMALL SPILLS, TAKE UP WITH SAND OR
OTHER ABSORBENT MEDIUM AND PLACE INTO CONTAINERS FOR LATER
DISPOSAL. NO SMOKING, FLAMES OR FL ARE IN HAZ AREA.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM IGNITION SOURCES.
PROTECT FROM HIGH HEAT. KEEP CONTAINERS CLOSED WHEN NOT IN USE.
Other Precautions:NOT APPLICABLE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED AT LOW LEVELS. WEAR NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST OR GENERAL DILUTION VENTILATION SYSTEM.
Other Protective Equipment:NONE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP: FAILURE/WITHIN FIRST 24 HOURS FROM PULM EDEMA.
PATIENTS WHO HAVE PRLNGD COMA/CONVULSIONS MAY HAVE IRREVERSIBLE
BRAIN DMG. MASSIVE DOSES MAY CAUSE INTRAVASCULAR HEMOLYSIS.
CHRONIC: EYE : PRLNGD/RPTD CONT MAY CAUSE CONJUNCT. SKIN:
RPTD/PRLNGD CONT MAY CAUSE DERM. INHAL: RPTD EXPOS MAY CAUSE (ING
4)
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:369F,187C
Spec Gravity:1.0
Appearance and Odor:ODORLESS, COLORLESS, HYGROSCOPIC, VISCOUS LIQUID
WITH SLIGHTLY ACID TASTE.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ALKALI METALS (FORMS HYDROGEN GAS), ATTACKS PLASTICS.
Stability Condition to Avoid:MAY BE IGNITED BY HEAT OR FLAMES.
CONTAINER MAY EXPLODE IN HEAT FROM FIRE. VAPOR EXPLOSION HAZARD
INDOORS.
Hazardous Decomposition Products:DECOMPOSES WHEN HEATED TO FORM
PEROXIDES AND PROPIONALDEHYDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:8903E AMP DIELECTRIC TAPE (BUTYL RUBBER SEALER)
Preparer's Name:W. KAUFFMANN
CAGE:LO364
CAGE:00779
CAGE:LO364
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE - QUARTZ (SUBSTANCE WON'T BE RELEASED
UNDER NORMAL USE)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST;9596
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL:NEGLIGIBLE HAZ @AMBIENT
TEMP.HOWEVER IF PRODUCT HEATED IT MAY CAUSE IRRIT TO UPPER RESP
TRACT. EYE:MAY PRODUCE MILD IRRIT. SKIN:MAY PRODUCE MILD
IRRIT.REPEATED COTNACT W/SKIN MAY CAUSE DERM IN S ENSITIVE
INDIVIDUALS. INGEST:MINIMAL TOXICITY.
Explanation of Carcinogenicity:PER MSDS:SILICA-CRYSTALLINE QUARTZ IS
PORBABLY CARCINOGENIC TO HUMANS PER IARC.
Effects of Overexposure:UPPER RESPIRATORY TRACT IRRIT FROM HEATING
MATL. MILD EYE/SKIN IRRITATION. DERMATITIS IN SENSITIVE
INDIVIDUALS. MINIMAL TOXICITY BY INGEST.
Medical Cond Aggravated by Exposure:REPEATED CONTACT WITH SKIN MAY
CAUSE DERMATITIS IN SENSITIVE INDIVIDUALS.
======================= First Aid Measures =======================
First Aid:INHAL:RESP SYMPT DEVELOP MOVE AWAY FRM EXPO SOURCE & INTO
FRESH AIR.SYMPT PERSIST GET MED ATTN.NOT BREATH IMMED BEGIN ART
RESP.BREATH DIFFI DEVELOP ADMIN OXY BY QUALIFIED PERSON.KEEP
WARM/QUIET.SEEK I MMED MED ATTN. EYE:IRRIT/REDNESS DEVELOPS MOVE
AWAY FROM EXPO & INTO FRESH AIR.FLUSH W/CLEAN WATER LIFTING
UPPER/LOWER LIDS FOR @LEAST 15MINS.SYMPT PERSIST SEEK MED ATTN.
SKIN:REMOVE CONTAMIN (SUPPLE)
===================== Fire Fighting Measures =====================
Flash Point:>200F,>93C
Lower Limits:N/D
Upper Limits:N/D
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures:FULL EMERGENCY EQPMT W/SELF-CONTAINED
BREATHING APPARATUS & FULL PROT CLOTH SHOULD BE WOERN BY
FIREFIGHTERS.MOVE UNDMG CNTNR FROM SPILL AREA W/O RISK.
Unusual Fire/Explosion Hazard:SILICA-CRYSTALLINE MAY BE RELEASED DURING
COMBUSTION.
================== Accidental Release Measures ==================
Spill Release Procedures:MATL IN CONTACT W/HOT OBJ AVOID BREATH
FUMES.REMOVE IGN SOURCES.COVER SPILL W/EXCESS OF INORG ABSORBENT
MATL(VERMICULITE).SWEEP UP RESIDUALS.PLACE IN LABEL DR.PREVENT
RUNOFF FROM ENTERING SEWERS/STREA MS/OTHER BODIES OF WATER.IF SO
CALL PROP AUTHORITI
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN WELL VENTI AREA AWAY FROM
STORNG OXIDIZING AGENTS/SOURCES OF HEAT/ING.AVOID REP/PROL CONTACT
W/MATL.IF MATL HEATED AVOID INHAL VAPORS.
Other Precautions:DO NOT EAT/SMOKE IN AREAS WHERE MATL IS USED/STORED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WORKPLACE EXPO LIMIT OF PROD/COMPONENT EXCEEDED
NIOSH/MSHA RESP IS ADVISED IN ABSENCE OF PROPER ENVIRO
CONTROL.ENGINEERING OR ADMINISTRATIVE CONTROLS SHOULD BE
IMPLEMENTED TO REDUCE EXPOSURE.
Ventilation:PROVIDE SUFFICIENT MECH(GEN &/OR LOC EXHAU)VENTI TO
MAINTAIN EXPO BELOW OSHA PEL & ACGIH TLV LIMITS.
Other Protective Equipment:EMERGENCY EYE WASH STATIONS & SAFETY SHOWERS
AVAILABLE IN WORKAREA.IMPERVIOUS CLOTH SHOULD BE WORN AS NEEDED.
Work Hygienic Practices:FOLLOW GOOD HYGENIC PRACTICES TO AVOID
POTENTIAL CHRONIC EFFECTS.CONTAMIN CLOTH SHOULD BE LAUNDERED BEF
REUSE.
Supplemental Safety and Health
1STAID:CLOTH.CLEANSE AREA WELL W/COPIOUS AMTS OF WATER FOR @LEAST
15MINS.IRRIT/REDNESS DEVELOP/PERSIST GET MED ATTN.INGEST:DO NOT
INDUCE VOMIT.GET MED ATTN IMMED. PER ED SHOEMAKER'S (H.B.FULLER
AUTOMO TIVE TECH SYS,INC) FAX OF 14JUN96 STATES 8903E IS NO LONGER
MANUFACTURED & THIS MSDS IS THE MOST RECENT.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:N/D
Vapor Pres:N/D
Vapor Density:N/D
Spec Gravity:1.34 +/- 0.03
pH:N/D
Evaporation Rate & Reference:N/D
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK COLOR, MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID STRONG ACIDS, OXIDIZING AGENTS, AND EXCESSIVE HEAT.
Stability Condition to Avoid:AVOID ALL POSSIBLE SOURCES OF IGNITION &
EXCESSIVE HEAT.
Hazardous Decomposition Products:THERM DECOMPOSITION MAY PRODUCE CARBON
DIOXIDE, CARBON MONOXIDE, & OTHER TOXIC DECOMPOSITION PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:112785600 CK/NAC R2
Kit Part:Y
Preparer's Name:MICHAEL A FAZIO
CAGE:32239
CAGE:32239
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM AZIDE, AZIDE
CAS:26628-22-8
RTECS #:VY8050000
Fraction by Wt: 0.1%
Other REC Limits:0.1 PPM
OSHA PEL:0.3 MG/CUM
ACGIH TLV:0.3 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SODIUM AZIDE-A PURE FORM, IS
CONSIDERED A POSION & MAY ALTER GENETIC MATERIAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SODIUM AZIDE-HEADACHE, DROWSINESS, VOMITING.
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LARGE VOLUMES OF WATER FOR 15 MINS. SKIN: FLUSH
AREAS W/LARGE VOLUMES OF WATER FOR 15 MINS. INGESTION: KEEP WARM &
QUIET. INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN/CPR IF NEEDED.
OBTA IN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:>392F
Extinguishing Media:USE MEDIA SPECIFIC FOR SITE CONDITIONS.
Fire Fighting Procedures:WEAR SCBA & PROTECTIVE GARMENTS. IF POSSIBLE,
HAVE THIS PRODUCT REMOVED FROM SCENE.
Unusual Fire/Explosion Hazard:THIS PRODUCT CONTAINS SODIUM AZIDE WHICH
IS SHOCK & HEAT SENSITIVE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. IF DRY, MOP UP, PLACE IN A
SUITABLE CONTAINER, SEAL, LABEL & HOLD FOR DISPOSAL. SOLUTION: USE
AN ABSORBENT MATERIAL TO CONTAIN/PICKUP. ONCE SPENT, PLACE
CONTAMINATED DISPOSABLE INTO A SUITABLE CONTAINER/SEAL/LABEL &
HOLD FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT 35.6-46.4F.
Other Precautions:AVOID CONTACT W/SKIN/EYES. DON'T EAT, DRINK/SMOKE
WHILE WORKING W/REAGENTS. DON'T MOUTH PIPETTE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NON REQUIRED IF VENTILATION IS ADEQUATE.
Ventilation:ADEQUATE GENERAL EXHAUST.
Other Protective Equipment:EYE WASH STATIONS, DELUGE SHOWERS, LAB COAT.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
SPILLS: UPON COMPLETION OF OBSERVE APPROPRIATE CHEMICAL HYGIENE. CLEAN
UP, WASH SITE W/WATER.
================== Physical/Chemical Properties ==================
Solubility in Water:COMPLETE (REAGENT)
Appearance and Odor:CLEAR COLORLESS LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SODIUM AZIDE-HEAVY METALS, STRONG OXIDIZERS, STRONG ACIDS, ACID
CHLORIDE, COPPER, LEAD PLUMBING.
Stability Condition to Avoid:EXCESS HEAT, FLAME, PRESSURE. SODIUM
AZIDE-SHOCK & HEAT SENSITIVE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.SODIUM AZIDE-WHEN DISPOSING DOWN THE DRAIN, FLUSH
W/LARGE VOLUMES OF WATER. CLEAR EXPOSED METAL SURFACES W/10 %
SODIUM HYDROXIDE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DOPAMINE HYDROCHLORIDE
CAGE:GO395
CAGE:GO395
CAGE:60567
============= Composition/Information on Ingredients =============
Ingred Name:DOPAMINE HYDROCHLORIDE*95-1*
CAS:62-31-7
RTECS #:UX1092000
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(MOUSE): 5213 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE, SKIN &/RESPIRATORY TRACT
IRRITATION. POSSIBLE HYPERSENSITIZATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYE, SKIN &/RESPIRATORY TRACT IRRITATION.
POSSIBLE HYPERSENSITIZATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. INGESTION: FLUSH MOUTH
W/WATER. SKIN: FLUSH AREA W/WATER. EYES: FLUSH W/WATER. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CO2, FOAM AS APPROPRIATE
FOR SURROUNDING FIRE & MATERIALS.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING EQUIPMENT &
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PERSONAL PROTECTIVE EQUIPMENT. VACUUM W/A
VACUUM CLEANER HAVING A HIGH EFFICIENCY PARTICULATE (HEPA) FILTER.
ABSORB LIQUID W/PAPER TOWELS. WIPE WORKING SURFACES TO DRYNESS,
WASH W/SOAP & WATER.
======================Handling and Storage ======================
Other Precautions:AVOID ALL CONTACT & INHALATION OF DUSTS, FUMES,
MISTS, &/VAPORS ASSOCIATED W/THE PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/OSHA APPROVED RESPIRATOR.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:DISPOSABLE PROTECTIVE APPAREL
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR COLORLESS SOLUTION W/NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:FREEZING, LIGHT, HEAT.
Hazardous Decomposition Products:EMITS TOXIC FUMES WHEN HEATED.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE SHOULD BE DISPOSED OF IAW/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:P-D-680 TY I
CAGE:60776
CAGE:60776
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA (PETROLEUM SPIRITS OR BENZIN)
CAS:8030-30-6
RTECS #:SE7555000
Fraction by Wt: 98%
OSHA PEL:100 PPM
Ingred Name:SOLVENT(100 DEGREE F FLASH POINT)
Fraction by Wt: 2%
===================== Hazards Identification =====================
Effects of Overexposure:INHAL CNS DAMAGE;RESP IRRIT;MUSCULAR
WEAKNESS;CONFUSION;IMPAIRED COORDINATION;HEADACHE;NAUSEA.
======================= First Aid Measures =======================
First Aid:SKIN:WASH IMMEDIATELY WITH SOAP & WATER. EYE: WASH
IMMEDIATELY WITH WATER FOR 15 MINUTES. INHAL:REMOVE FROM EXPOSURE
.PROVIDE FRESH AIR & REST. INGEST:DO NOT INDUCE VOMITING, CALL MD
IMMEDIATE.
===================== Fire Fighting Measures =====================
Flash Point:105F;41,TCC
Lower Limits:1.1
Upper Limits:6.0
Extinguishing Media:MECHANICAL FOAM, DRY CHEMICAL, WATER FOG, CO*2
Fire Fighting Procedures:WATER STREAM WILL SPREAD FIRE. USE FRESH AIR
RESPIRATORS.
Unusual Fire/Explosion Hazard:A VAPOR ACCUMULATION WOULD FLASH AND/OR
EXPLODE IF IGNITED. COMBUSTIBLE LIQUID.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNITION SOURCES, AVOID BREATHING
VAPORS, PROVIDE ADEQUATE VENTILATION, ABSORB SPILLAGE.CALL
EMERGENCY NUMBER IF SPILLAGE POSES THREAT TO MAN OR ENVIRONMENT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, WELL VENTILATED AREA.
KEEP CLOSURES TIGHT AND UPRIGHT TO PREVENT LEAKAGE. KEEP CLOSED
WHEN NOT IN USE. READ ALL WARNING LABELS.
Other Precautions:DO NOT TRANSFER TO UNMARKED CONTAINER. GROUND
CONTAINERS WHEN FILLING OR EMPTYING. USE ONLY WITH ADEQUATE
VENTILATION. (EQUIVALENT TO OUTDOORS VENTILATION. AVOID POTENTIAL
IGNITION SOURCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED SELF-CONTAINED BREATH APPAR
IF TLV IS EXCEEDED.
Ventilation:LOCAL/MECH RECOMND;USE EXPLOSION.PROOF EQUIP SEE SUP DATA.
Other Protective Equipment:AS REQUIRED TO AVOID SKIN CONTACT BREATHING
VAPORS.
Supplemental Safety and Health
VP & SPECIFIC GRAVITY VALUES ARE AT 60F. VENTILATION:EXHAUST TO
NON-DANGEROUS SPARK-FREE AREAS. AVOID POTENTIAL IGNITION SOURCES.
CONTAINER: 55 GALLON
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:317-370F
Vapor Pres:1.8
Vapor Density:4.9
Spec Gravity:0.7632
Evaporation Rate & Reference:0.12, N-BU AC=1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE WATER LIQUID, MILD HYDROCARBON ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID HEAT,SPARKS, FLAME & OTHER IGNITION
SOURCES.
Hazardous Decomposition Products:CARBON MONIXIDE IF BURNED WITH
INSUFFICIENT AIR.
==================== Disposal Considerations ====================
Waste Disposal Methods:MFR RECOMMENDS USING A QUALIFIED DISPOSAL
COMPANY TO INCINERATE OR OTHERWISE DISCARD AT AN APPROVED FACILITY.
DISPOSAL METHOD MUST BE IAW FEDERAL, STATE AND LOCAL CODES. DO NOT
INCINERATE CLOSED CONTA INERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SODIUM OXALATE
Resp. Party Other MSDS Num.:SS 720
Preparer's Name:MICHAEL RASZEJA
CAGE:6V042
CAGE:6V042
Contract Num:MDA414-99-A-0024-0090
CAGE:63759
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM OXALATE
CAS:62-76-0
RTECS #:KI1750000
= Wt:100.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: KIDNEYS, LIVER, CENTRAL
NERVOUS SYSTEM. INHALATION: CAUSES SEVERE IRRITATION TO MUCOUS
MEMBRANES AND UPPER RESPIRATORY TRACT. SKIN AND EYES: MAY CAUSE
SEVERE SKIN AND EYE IRRITATION. IN GESTION: WHEN TAKEN ORALLY IT
HAS A CAUSTIC EFFECT ON MOUTH, ESOPHAGUS AND STOMACH. MAY CAUSE
KIDNEY AND/OR LIVER DAMAGE.
Effects of Overexposure:TARGET ORGANS: KIDNEYS, LIVER, CENTRAL NERVOUS
SYSTEM. INHALATION: CAUSES SEVERE IRRITATION TO MUCOUS MEMBRANES
AND UPPER RESPIRATORY TRACT. SKIN AND EYES: MAY CAUSE SEVERE SKIN
AND EYE IRRITATION. IN GESTION: WHEN TAKEN ORALLY IT HAS A CAUSTIC
EFFECT ON MOUTH, ESOPHAGUS AND STOMACH. MAY CAUSE KIDNEY AND/OR
LIVER DAMAGE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH THOROUGHLY WITH WATER FOR AT LEAST 15 MINUTES,
LIFTING UPPER AND LOWER EYELIDS OCCASIONALLY. GET IMMEDIATE MEDICAL
ATTENTION. SKIN: FLUSH THOROUGHLY WITH WATER, THEN WASH WITH MILD
SOAP AN D WATER. INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING,
GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, GIVE
OXYGEN, GET IMMEDIATE MEDICAL ATTENTION. INGESTION: IF SWALLOWED,
IF CONSCIOUS, GIVE LARGE QUANTITIES OF MILK TO DRINK, AND INDUCE
VOMITING. CALL PHYSICIAN IMMEDIATELY. NEVER GIVE ANYTHING BY MOUTH
TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM.
Fire Fighting Procedures:WEAR A NIOSH/MSHA-APPROVED SELF-CONTAINED
BREATHING APPARATUS AND PROTECTIVE CLOTHING TO PREVENT CONTACT WITH
SKIN AND EYES. USE FLOODING AMOUNTS OF WATER IN EARLY STAGES OF
FIRE. (1996 EMERGENCY RESP ONSE GUIDEBOOK, DOT P 5800.7, GUIDE PAGE
NO. 151).
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS; CAN REACT VIGOROUSLY WITH
OXIDIZING MATERIALS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SUITABLE PROTECTIVE CLOTHING, RECOVER FOR
USE IF NOT CONTAMINATED. SWEEP UP AND PLACE IN A SUITABLE CONTAINER
FOR PROPER DISPOSAL. FLUSH SPILL AREA WITH WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING DUST. USE WITH
ADEQUATE VENTILATION. STORE IN A COOL, DRY PLACE AWAY FROM FOOD
PRODUCTS. WASH THOROUGHLY AFTER HANDLING. KEEP CONTAINER TIGHTLY
CLOSED WHEN NOT IN USE.
Other Precautions:DO NOT TAKE INTERNALLY. AVOID CONTACT WITH SKIN, EYES
AND MUCOUS MEMBRANES. REMOVE AND WASH CONTAMINATED CLOTHING. FOR
LABORATORY USE ONLY. NOT FOR DRUG, FOOD OR HOUSEHOLD USE. KEEP OUT
OF REACH OF CH ILDREN. READ LABEL ON CONTAINER BEFORE USING. DO
NOT WEAR CONTACT LENSES WHEN WORKING WITH CHEMICAL S.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NEEDED N NORMAL LABORATORY HANDLING. IF
DUST CONDITIONS PREVAIL, WORK IN VENTILATION HOOD OR WEAR A
NIOSH/MSHA-APPROVED DUST MASK OR RESPIRATOR.
Ventilation:LOCAL EXHAUST-RECOMMENDED. MECHANICAL
(GENERAL)-RECOMMENDED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:T4
Boiling Pt:B.P. Text:DECOMPOSES
Melt/Freeze Pt:=250.C, 482.F
M.P/F.P Text:250-270C DEC.
Vapor Pres:NEGLIGIBLE AS SOLID
Vapor Density:NO DATA
Spec Gravity:2.34 @20C
Evaporation Rate & Reference:NON-VOLATILE
Solubility in Water:3.7 GRAMS/100ML WATER@20C
Appearance and Odor:COLORLESS CRYSTALS OR WHITE CRYSTALLINE POWDER; NO
ODOR
Percent Volatiles by Volume:NON-VOLATILE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:EXCESSIVE TEMPERATURE AND HEAT.
Hazardous Decomposition Products:COMBUSTION WILL PRODUCE CARBON
DIOXIDE(CO2) AND PROBABLY CARBON MONOXIDE (CO).
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE OR LOCAL LAWS. THESE DISPOSAL GUIDELINES ARE
INTENDED FOR THE DISPOSAL OF CATALOG-SIZE QUANTITIES ONLY. DISPOSE
OF IN AN APPROVED INC INERATOR OR CONTRACT WITH AN APPROVED AND
LICENSED DISPOSAL AGENCY.
=================== MSDS Transport Information ===================
Transport Information:TOXIC SOLID, INORGANIC, NOS (SODIUM OXALATE),
6.1, UN3288M PG III
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ON AN' ON
Preparer's Name:THOMAS J. MITCHELL
CAGE:23212
CAGE:23212
============= Composition/Information on Ingredients =============
Ingred Name:DIETHYLENE GLYCOL MONOETHYL ETHER (SARA 313)
CAS:111-90-0
RTECS #:KK8750000
Fraction by Wt: 7%
OSHA PEL:NOT EST
ACGIH TLV:NOT EST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:VAPORS MAY IRRITATE EYES AND
RESPIRATORY TRACT AND MAY PRODUCE SYMPTOMS OF HEADACHE AND NAUSEA
IN POORLY VENTILATED AREAS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:UNKNOWN.
======================= First Aid Measures =======================
First Aid:INGEST:IF SWALLOWED DRINK LARGE QTY WATER; CALL MD.
SKIN:FLUSH W/WATER. EYE:IMMEDIATELY FLUSH W/WATER AT LEAST 15
MINUTES. CALL MD.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:NA
Fire Fighting Procedures:NA
Unusual Fire/Explosion Hazard:NA
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILLS:FLUSH W/WATER TO SEWER SYSTEM.
DIKE & CONTAIN LARGE SPILL W/INERT MATERIAL & TRANSFER LIQUID TO
CONTAINERS FOR RECOVERY OR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED.
Ventilation:GOOD GENERAL VENT SHOULD BE SUFFICIENT FOR MOST CNDTNS. LOC
EXHST VENT MAY BE NEC FOR SOME OPERATIONS.
Other Protective Equipment:NONE NECESSARY.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:210F,99C
Vapor Pres:18 @ 75F
Spec Gravity:1.042 (H*20=1)
pH:9-9.3
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:TRANSLUCENT EMULSION, SLIGHT AMMONIACAL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATION OR APPROVED LANDFILL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PR-1431-G TYPE III, PART A
Preparer's Name:NG
CAGE:DO563
CAGE:83574
CAGE:DO563
============= Composition/Information on Ingredients =============
Ingred Name:CLAY (MAGNESIUM ALUMINUM SILICATE)
CAS:1343-90-4
RTECS #:OM4360000
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM
Ingred Name:MAGNESIUM DICHROMATE
CAS:13423-61-5
OSHA PEL:0.5 MG/CUM
ACGIH TLV:0.5 MG/CUM
Ingred Name:CALCIUM DICHROMATE
CAS:14307-33-6
OSHA PEL:0.5 MG/CUM
ACGIH TLV:0.5 MG/CUM
Ingred Name:SILICA AMORPHOUS HYDRATED, SILICEOUS EARTH, FUMED SILICA
CAS:7631-86-9
RTECS #:VV7322000
Other REC Limits:3 MG/CUM RESP. DUST
OSHA PEL:80 MG/CUM
ACGIH TLV:6 MG/CUM TOTAL DUST
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION. INHALATION:
(MIST OR DUST OF DRIED MATERIALS) CAN IRRITATE MUCOUS MEMBRANES.
MAY CAUSE BRONCOASTHMA. INGESTION: MAY IRRITATE STOMACH &
INTESTINES. LARGE AMOUNTS CAN CAUSE LIVER & KIDNEY DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES/SKIN: IRRITATION. INHALATION: (MIST OR
DUST OF DRIED MATERIALS) CAN IRRITATE MUCOUS MEMBRANES. MAY CAUSE
BRONCOASTHMA. INGESTION: MAY IRRITATE STOMACH & INTESTINES. LARGE
AMOUNTS CAN CAUSE LIVER & KIDNEY DAMAGE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LUKE WARM WATER FOR 15 MINUTES. CONSULT
PHYSICIAN. SKIN: WASH W/SOAP & WATER. IF IRRITATION PERSISTS,
CONSULT PHYSICIAN. INHALATION: REMOVE TO FRESH AIR. CONSULT
PHYSICIAN. INGESTION: CO NSULT PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:USE COMPLETE PERSONAL PROTECTION.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE & COVER THE SPILL W/A NON-OXIDIZABLE
ABSORBENT & SCOOP INTO CONTAINER. SPRINKLE SODIUM THIOSULFATE ON
THE RESIDUE. WORK INTO RESIDUE. SCOOP INTO DISPOSAL CONTAINER.
CLEAN UP W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:WASH THOROUGHLY AFTER HANDLING &
BEFORE SMOKING OR EATING. AVOID INGESTION.
============= Exposure Controls/Personal Protection =============
Ventilation:PROVIDE LOCAL EXHAUST VENTILATION TO MAINTAIN VAPOR <PEL.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE SMOKING
OR EATING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:1.53
Solubility in Water:COMPLETE
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
EASILY OXIDIZABLE MATERIALS.
Hazardous Decomposition Products:CHROMIUM COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:EPA WASTE NO. D-007. DISPOSE OF SPILLAGE IN
COMPLIANCE W/STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RAPIDOPRINT ACTIVATOR G-182B
CAGE:31023
CAGE:31023
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 3.0%
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:MAY CAUSE SKIN IRRIT, EYE BURNS
======================= First Aid Measures =======================
First Aid:SKIN: FLUSH W/WATER. EYES: FLUSH W/WATER, OBTAIN IMMED MED
ATTENT.
================== Accidental Release Measures ==================
Spill Release Procedures:DILUTE W/WATER, DISPOSE IAW LOCAL, STATE, FED
REG
======================Handling and Storage ======================
Other Precautions:FOLLOW ALL INSTRUCTIONS ON LABEL
============= Exposure Controls/Personal Protection =============
Ventilation:MECH VENT, REC
Other Protective Equipment:PROTECTIVE APRON
Supplemental Safety and Health
PH >13.0
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Spec Gravity:1.077
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONTACT W/A1, ZN SHOULD BE AVOIDED
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CLEAR SEMI-GLOSS LACQUER, 102-123
CAGE:33244
CAGE:33244
============= Composition/Information on Ingredients =============
Ingred Name:XYLENE. VP: 5.1 @ 68F
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 1%
OSHA PEL:100 PPM;150 PPM STEL
ACGIH TLV:100 PPM;150 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PROPIONIC ACID, 3-ETHOXY-, ETHYL ESTER;
(ETHYL-3-ETHOXYPROPIONATE). VP: 1.1 @ 77F
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: <5.0%
Ingred Name:TOLUENE. VP: 22 @ 68F
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 4%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETIC ACID, BUTYL ESTER; (N-BUTYL ACETATE). VP: 10 @ 68F
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 20%
OSHA PEL:150 PPM;200 PPM STEL
ACGIH TLV:150 PPM;200 PPM STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE) (MEK). VP: 70 @ 68F
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 11%
OSHA PEL:200 PPM;300 PPM STEL
ACGIH TLV:200 PPM;300 PPM STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:LACOLENE; (LACTOL SPIRITS). VP: 38 @ 68F
CAS:64742-89-8
Fraction by Wt: 10%
OSHA PEL:500 PPM (MFR)
Ingred Name:ISOPROPYL ALCOHOL; (ISOPROPANOL). VP: 33 @ 68F
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: <5.0%
Other REC Limits:500 PPM (MFR)
OSHA PEL:400 PPM;500 PPM STEL
ACGIH TLV:400 PPM;500 PPM STEL
Ingred Name:BENZIN; (STANDARD 265). VP: 26 @ 77F
CAS:8030-30-6
RTECS #:DE3030000
Fraction by Wt: 10%
OSHA PEL:500 PPM (MFR)
ACGIH TLV:225 PPM (MFR)
Ingred Name:ISOBUTYL ALCOHOL. VP: 8.8 @ 68F
CAS:78-83-1
RTECS #:NP9625000
Fraction by Wt: <5.0%
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SUPP DATA: REFERRED TO AS SOLV/PAINTER'S SYNDROME).
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:(ACUTE & CHRONIC)INHAL:ANESTH.IRRIT OF
RESP TRACT W/HDCH, NAUS, DIZZ, UNCON/COMA.EXPOS TO HIGH VAP CONC
CAN LEAD TO DEPRESS OF CNS.INGEST:CAN CAUSE DEPRESS OF CNS.ASPIR OF
VOMIT IN LUNGS CAN CAUSE CHE M PNEUM WHICH CAN BE FATAL.LAB STUDIES
HAVE SHOWN THAT TOLUENE CONTAINS COMPONENT WHICH CAN CAUSE IRREV
(SUPP DATA)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:INHAL:FLUSHING, HDCH, DIZZ, NAUS, VOMIT, LOSS
OF CONSCIOUSNESS/EVEN ASPHY.TOLUENE IS CONSIDERED TO BE AN OCCUP
REPRO HAZ. EYE:REDDENING & BURNING SENSATION, WATERING & BLURRED
VISION. SKIN:DRYING, RED DENING, IRRIT. SKIN ABSORP:SEVERE IRRIT,
DEFAT OF SKIN, DERMAT. INGEST:HDCH, DIZZ, NAUS, VOMIT, DIARR.
Medical Cond Aggravated by Exposure:SINUS AND LARYNGEAL CANCERS,
PRE-EXISTING HEART, LUNG, LIVER, AND SKIN DISORDERS.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOS,RESTORE BRTHG;ADMIN OXYGEN WHEN
NEC.CALL MD IMMED.EYE:WASH THORO W/LRG AMTS OF WATER FOR AT LEAST
15 MIN W/LIDS OPEN.CALL MD IMMED.SKIN:WASH W/LRG AMTS OF
WATER.WATCH FOR SKIN DE-OILING.IF IRRIT & DRYNESS PERSISTS, CALL
MD.INGEST:GIVE ONE OR TWO GLASSES OF WATER TO DILUTE.DO NOT INDUCE
VOMIT.CALL MD IMMED.KEEP PATIENT WARM & QUIET.ASPIR OF VOMIT IN
LUNGS CAN (SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point:40.0F,4.4C
Lower Limits:1%
Upper Limits:10.9%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER MAY BE USED TO COOL CONTAINERS TO PREVENT PRESS BUILDUP,
POSS AUTOIGNIT/EXPLO DUE TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:CLSD CNTNRS MAY EXPLD WHEN EXPSD TO
EXTREME HEAT.KEEP WORK AREA FREE FROM SOURCES OF IGNIT.VAPS MAY
TRAVEL ALONG GROUND/BE MOVED BY VENT TO SOURCES OF(SUPPDATA)
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA. REMOVE ALL SOURCES OF IGNITION.
CONTAIN AND REMOVE WITH INERT ABSORBENT AND NON-SPARKING TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CLOSURE TIGHT & CNTNR IN UPRIGHT
POSITION. STORE AWAY FROM HEAT/OTHER SOURCES OF IGNIT. USE & STORE
THIS PROD W/ADEQ VENT.
Other Precautions:CNTNR MUST BE GROUNDED AND/OR BONDED DURING LIQ
TRANSFER. VAPS GIVEN OFF MAY TRAVEL ALONG GROUND/BE MOVED BY VENT
TO SOURCES OF IGNIT. EVEN RESIDUE MAY IGNIT EXPLO. AVOID PRLNGD
BRTHG OF VAPS, SKIN/EY E CONT. SHOULD CONT BE MADE, (SUPP DATA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED CHEMICAL MECHANICAL FILTER
RESPIRATOR.
Ventilation:REQUIRED, 200 CFM MINIMUM.
Other Protective Equipment:EYEWASH AND SAFETY SHOWERS IN WORK AREA ARE
RECOMMENDED.
Work Hygienic Practices:WASH WITH SOAP AND WATER, REMOVE CONTAMINATED
CLOTHING BEFORE HANDLING FOOD OR SMOKING.
Supplemental Safety and Health
EXPLO HAZ:IGNIT.RESIDUE IN EMPTIED CNTNRS CAN EXPLD/IGNITE. HLTH
HAZ:CHANGES IN GENETIC MATL OF CELL. FIRST AID PROC:CAUSE PNEUM
WHICH CAN BE FATAL. OTHER PREC:REMOVE SATURATED CLTHG & FLUSH
AFFECTED AREAS W/WATER. RPTD/PRLNGD OCCUP OVEREXP TO SOLV PRESENT
MAY CAUSE PERM BRAIN & NERV SYS DMG (SOMETIMES (ING 10)
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:174F,79C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:0.9 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:TURBID LIQUID WITH DISTINCT SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ACIDS, ALKALIES AND SELECTED AMINES.
Stability Condition to Avoid:AVOID PROLONGED BREATHING OF VAPORS, SKIN
OR EYE CONT. STORE AWAY FROM HEAT AND SOURCES OF IGNITION.
Hazardous Decomposition Products:MAY FORM TOXIC MATERIALS LIKE CO*2,
CO, OXIDES OF NITROGEN, SMOKE, TOXIC VAPORS AND FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIF
CAGE:DO175
CAGE:DO175
CAGE:8X084
============= Composition/Information on Ingredients =============
Ingred Name:FORMALDEHYDE
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: 2.17%
OSHA PEL:1 PPM;2 PPM STEL
ACGIH TLV:0.3 PPM, C
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:ETHYL ALCOHOL (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 19.50%
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC: CORROSIVE, IRRITANT,
COMBUSTIBLE, SENSITIZER, TOXIC. EYE: IRRITANT, TEARING, EYE DAMAGE,
BURNING, SKIN IRRITANT. INHAL: COUGHING, WHEEZING, LARYNGITIS,
SHORTNESS OF BREATH, HEADACHE. IN GEST: NAUSEA, VOMITING, COLLAPSE
AND UNCON.
Explanation of Carcinogenicity:FORMALDEHYDE: IARC MONOGRAPHS,
SUPPLEMENT, VOL 7, PG 211, 1987: GRP 2A. NTP 6TH ANNUAL REPORT ON
CARCINS, 1991: (SUPDAT)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE INDICATED.
======================= First Aid Measures =======================
First Aid:OBTAIN MEDICAL ATTENTION. EYE: FLUSH WITH WATER FOR AT LEAST
15 MINUTES. SKIN: FLUSH WITH WATER FOR 15 MINUTES. INHAL: REMOVE TO
FRESH AIR, IF BREATHING STOPS GIVE ARTF RESP. INGEST: ADMINISTER 4
GLAS SES OF WATER AND INDUCE VOMITING BY TOUCHING BACK OF THROAT
W/FINGER.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA APPROPRIATE FOR SURROUNDING FIRE CONDITIONS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MAY PRODUCE HAZARDOUS DECOMPOSITION
PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB ON PAPER, VERMICULITE, ETC.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT EXCEED TLV CONTAINERS.
POTENTIALLY HAZARDOUS WHEN EMPTY. DO NOT REUSE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR IF TLV
EXCEEDED.
Ventilation:GENERAL MECHANICAL VENTILATION IS USUALLY ADEQUATE UNDER
NORMAL USE.
Other Protective Equipment:PROTECTIVE CLOTHING SHOULD BE WORN.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLAN OF CARCIN: ANTIC TO BE CARCIN. ANIMAL: NASAL TUMORS.
================== Physical/Chemical Properties ==================
HCC:T6
Solubility in Water:UNLIMITED
Appearance and Odor:COLORLESS LIQUID, ALCOHOL ODOR
Percent Volatiles by Volume:21.7
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG BASES.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE INDICATED.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT FEDERAL, STATE, AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.