text
stringlengths 789
11.3k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
* Exposure Controls/Personal Protection *
Respiratory Protection:USE WELD FUME RESPIRATOR OR AIR SUPPLIED
RESPIRATOR WHEN CUTTING, GRINDING OR WELDING IN A CONFINED SPACE OR
WHERE LOCAL EXHAUST OR GENERAL VENTILATION DOES NOT KEEP EXPOSURE
BELOW RECOMMENDED LIMITS. MONITOR THE AIR QUALITY INSIDE THE
WELDER'S HELMET, IF WORN, AND/OR THE WORKER'S BREATHING ZONE TO
DETERMINE IF A RESPIRATOR (SUPPLEMENTAL SAFETY AND HEALTH)
Ventilation:USE ENOUGH VENTILATION WHEN CUTTING, GRINDING OR WELDING TO
KEEP DUST, FUMES AND GASES FROM THE WORKER'S BREATHING ZONE AND
(SUPPLEMENTAL SAFETY AND HEALTH)
(WORK HYGENIC PRACTICES)
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
CUTTING, GRINDING OR WELDING. DO NOT EXPOSE SKIN TO (SUPPLEMENTAL
SAFETY AND HEALTH)
OR WELDING. IN ADDITION, WHEN HOT CUTTING OR WELDING, WEAR WELDING
HELMET OR FACE SHIELD WITH FILTER LENS. SELECT WELDING LENS SHADE
FROM AWS PUB F2.2.
Supplemental Safety and Health
RESP PROT (CONT): IS REQUIRED AND THE TYPE NEEDED. USE ONLY NIOSH
APPROVED RESPIRATORS. VENTILATION (CONT): GENERAL AREA. KEEP
EXPOSURE BELOW THE LIMITS SPECIFIED IN (INGREDIENTS AND REACTIVITY)
SE CTIONS. OTHER PROT EQUIP (CONT): RADIATION WHEN HOT CUTTING
OR WELDING. PROVIDE PROTECTIVE SCREENS TO SHIELD OTHERS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:IRON (FE)
Fraction by Wt: BALANCE
OSHA PEL:NONE
ACGIH TLV:NONE
Ingred Name:CHROMIUM (CR)
= Wt:1.5
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:NICKEL (NI)
= Wt:.1
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:THIS PRODUCT POSES NO HEALTH HAZARD AS
SHIPPED BUT MAY POSE A HEALTH HAZARD DURING USE. ELECTRIC ARC
WELDING RAYS CAN INJURE EYES AND BURN SKIN. DUST, FUMES AND GASES
CAN BE DANGEROUS TO YOUR HEALTH. LUNG DAMAGE MAY RESULT FROM
OVEREXPOSURE. SECTIONS (INGREDIENTS AND REACTIVITY) LIST SPECIFIC
HAZARDOUS INGREDIENTS, REACTION PRODUCTS AND OSHA PEL'S AND ACGIH
TLV'S. PRIMARY ROUTE OF ENTRY: FUMES, GASES AND DUST CAN BE A
HEALTH HAZARD THRU INHALATION. ACUTE EXPOSURE: SHORT TERM EXPOSURE
TO WELDING FUMES, GASES OR DUST MAY RESULT IN DISCOMFORT SUCH AS
DIZZINESS, NAUSEA, FEVER, DRYNESS AND/OR (S IGNS AND SYMPTOMS OF
OVEREXPOSURE)
Effects of Overexposure:HEALTH HAZARDS ACUTE AND CHRONIC (CONT):
IRRITATION OF NOSE, THROAT AND EYES. SKIN SENSITIVITY MAY ALSO BE
NOTED. ACUTE EXPOSURE CAN RESULT IN THE SAME SYMPTOMS EXCEPT TO A
GREATER DEGREE AS WELL AS W ATERY EYES, HEADACHE, BREATHING
DIFFICULTY, FREQUENT COUGHING AND/OR CHEST PAINS. SOME TOXIC GASES
MAY CAUSE PULMONARY EDEMA, ASPHYXIATION AND EXCESSIVE EXPOSURE CAN
BE FATAL. CHRONIC EXPOSURE: CHRON IC EXPOSURE MAY RESULT IN
NEUROLOGICAL DAMAGE, LUNG FIBROSIS, PNEUMONCONIOSIS AND OTHER LUNG
DISEASES. NICKEL AND CHROMIUM ARE CONSIDERED POSSIBLE CARCINOGENS
(TOXICOLOGICAL INFO)
Medical Cond Aggravated by Exposure:SOME WORKERS MAY EXPERIENCE
DISCOMFORT AT CONCENS BELOW THE TLV & OTHERS MAY BE AFFECTED BY
PRE-EXISTING CNDTNS OR OTHER OCCUPATIONAL ILLNESS BECAUSE OF WIDE
VARIATION IN INDIVIDUAL SUSCEPTIBILITIES.
* First Aid Measures *
First Aid:IN CASE OF ELECTRIC SHOCK, TURN OFF POWER PRIOR TO REMOVAL
FROM EXPOSURE AREA AND ADMINISTRATION OF FIRST AID. INHALATION:
REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT ADMINISTER OXYGEN.
IF NOT BRE ATHING BEGIN ARTIFICIAL RESPIRATION. IF NO DETECTABLE
PULSE BEGIN EXTERNAL HEART MASSAGE. SKIN: WASH AFFECTED AREA WITH
SOAP AND WATER. EYES: FLUSH WITH LARGE AMOUNTS OF FRESH WATER FOR
* Fire Fighting Measures *
Flash Point:NONFLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONFLAMMABLE; HOWEVER, ARCS, SPARKS AND
MOLTEN METAL CAN IGNITE FLAMMABLES AND COMBUSTIBLES OR CAUSE
EXPLOSIONS.
* Accidental Release Measures *
Spill Release Procedures:CLEAN UP ANY GRINDING DUST OR WASTE RESIDUES
AND PLACE IN SUITABLE DEPARTMENT OF TRANSPORTATION (DOT) APPROVED
CONTAINERS AND DISPOSE OF IN FULL COMPLIANCE WITH FEDERAL, STATE
AND LOCAL REGULATIONS. A VOID INHALATION AND SKIN EXPOSURE.
* Physical/Chemical Properties *
HCC:T6
Appearance and Odor:BARE FILLER METALS ARE SOLID WIRE.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:WELDING AND HOT CUTTING FUMES AND
GASES CANNOT BE CLASSIFIED SIMPLY. THEIR COMPOSITION AND QUANTITY
ARE DEPENDENT ON THE METAL BEING WELDED, THE PROCEDURES, PROCESSES
AND TYPE OF WIRE (ECOLOGICAL INFO)
* Toxicological Information*
Toxicological Information:N/P. SIGNS AND SYMPTOMS OF
OVEREXPOSURE (CONT): FOR THIS CLASSIFICATION WERE FROM OPERATIONS
OTHER THAN WELDING OF CHROMIUM OR NICKEL. THERE IS CONSIDERABLE
CONTROVERSY ON THE EXTENT OF RESPIRA TORY CANCER PROBLEMS DUE TO
NICKEL AND CHROMIUM. NEVERTHELESS EXPOSURES MUST BE MAINTAINED
BELOW THE LEVELS SPECIFIED IN (INGREDIENTS AND REACTIVITY)
SECTIONS.
* Ecological Information *
Ecological:N/P. HAZARDOUS DECOMPOSITION PRODUCTS (CONT): OR
ELECTRODES USED. OTHER INFLUENCING FACTORS ARE THE PRESENCE OF
CONTAMINENTS IN THE ATMOSPHERE. DECOMPOSITION PRODUCTS FROM THE
WELDING OR CUTT ING OPERATION INCLUDE THOSE FROM THE
VOLATILIZATION, REACTION AND/OR OXIDATION OF THE MATERIALS IN
(INGREDIENTS) SECTION AND MAY INCLUDE OXIDES OF THE METALS,
CHROMATES AND COMPLEX METALLICS. GASEOUS REACTION PRODUCTS MAY
INCLUDE CARBON MONOXIDE, OZONE AND NITROGEN OXIDES. CHLORINATED
SOLVENTS MAY BE DECOMPOSED INTO TAXIC GASES SUCH AS PHOSGENE. WHEN
ELECTRODES ARE CONSUMED, THE FUME AND GAS DECO MPOSITION PRODUCTS
(TRANSPORT INFO)
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN FULL COMPLIANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS.
* MSDS Transport Information *
Transport Information:N/P. ECOLOGICAL INFO (CONT): GENERATED
ARE DIFFERENT IN FORM FROM THE INGREDIENTS LISTED IN (INGREDIENTS)
SECTION. NEW COMPOUNDS NOT IN THE ELECTRODES MAY FORM. THE KNOWN
GASES AND FUMES THAT MAY FORM DURING WELDING OR HOT CUTTING AND
THEIR EXPOSURE LIMITS ARE NOTED IN THE FOLLOWING TABLE: ALUMINUM
MG/M3. CHROMIUM (CHROMATES), CAS # VARIES WITH COMPOUND, PEL
* Regulatory Information *
SARA Title III Information:N/P. TRANSPORT INFO (CONT): COBALT
PEL: 0.5 MG/M3, TLV: 0.1 MG/M3. TUNSTEN (W) (SOLUABLE), CAS #
DIOXIDE, PEL CEILING: 9 MG/M3, TLV: 5.6 MG/M3. (FEDERAL REGS)
Federal Regulatory Information:N/P. SARA III (CONT): OZONE,
THE LIMIT FOR WELDING FUMES NOT OTHERWISE CLASSIFIED IS 5 MG/M3.
SOME ELEMENTS OR COMPOUNDS WILL EXCEED THEIR PEL'S / TLV'S BEFORE
THE TOTAL FUMES EXCEED 5 MG/M3.
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:ORGANIC VAPOR RESPIRATOR WITH PARTICULATE FILTER
APPROVED BY NIOSH.
VELOCITY. MECHANICAL (GEN) ACCEPTABLE FOR SMALL VOL APPLICATN.
Other Protective Equipment:NONE
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:AROMATIC HYDROCARBON
Fraction by Wt: 1-5%
Other REC Limits:NONE SPECIFIED
Ingred Name:MINERAL SPIRITS
Other REC Limits:NONE SPECIFIED
Ingred Name:TRIMETHYLBENZENE (SARA III)
Fraction by Wt: .1-1%
Other REC Limits:NONE SPECIFIED
Ingred Name:VM&P NAPHTHA
Fraction by Wt: 1-5%
Other REC Limits:NONE SPECIFIED
Ingred Name:ALIPHATIC ACIDS
Fraction by Wt: .1-1%
Other REC Limits:NONE SPECIFIED
Fraction by Wt: 1-5%
Other REC Limits:NONE SPECIFIED
Ingred Name:LEAD (PB) (SARA III)
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:MANGANESE COMPOUND
Fraction by Wt: 1-5%
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES
Health Hazards Acute and Chronic:ACUTE; INHAL: RESP TRACT IRRIT,
HEADACHE, NAUSEA, CNS DEPRESSN, FATIGUE, UNCONSCIOUSNESS. INGEST:
SEVERE GI DISTURB (NAUSEA, VOMIT, ANOREXIA, CONSTIPATION). ASPIRATN
(LUNGS--CHEM PNEUMONIA-FATAL). EYE S: SEVERE IRRIT, RED, TEAR,
BLURRED VISION, CONJUNCTIVAL/CORNEAL INJURY. SKIN: IRRIT, DRY SKIN,
DERMATITIS/ULCERATION.
Explanation of Carcinogenicity:LEAD CHROMATE SUSPECTED TO CAUSE LUNG
CANCER. LISTED AS SUSPECT OF CARCINOGENIC POTENTIAL FOR MAN.
Effects of Overexposure:CHRONIC;INHAL/INGEST:KIDNEY,LIVER,OTHER
SYSTEMIC DAMAGE.AFFECT HIGHER BRAIN FUNCTION &MENTAL CAPACITY.LEAD
POISON(FATIGUE,SLEEP DISTURB,CONSTIPATN,COLIC,ANEMIA,NEURITIS).RBC
FORMATN,KIDNEY,CNS (ANOREX IA,METALLIC
TASTE,ANXIETY,NAUSEA,PALLOR,HEADACHE,IRRITABILITY,MUSCLE/JOINT
PAIN,TREMOR,NUMBNESS,DIZZINESS,HYPERTENSION).
* First Aid Measures *
First Aid:INHALATION: IF OVERCOME BY VAPORS, REMOVE TO FRESH AIR. IF
NOT BREATHING, RESTORE BREATHING. GET MEDICAL HELP OR DR IMMED.
EXCESS MATE RIAL WITH PAPER TOWELS OR RAGS. WASH WITH MILD SOAP &
WARM WATER. IF ANY REDNESS/SWELLING PERSISTS, GET MED AID.
INGESTION: IF INGESTED, DO NOT INDUCE VOMITING. GET MEDICAL HELP OR
PHYSICIAN IMMED.
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:0.9
Extinguishing Media:CARBON DIOXIDE OR DRY CHEMICAL
* SOLVENT ONLY
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. WATER SPRAY
SHOULD BE USED TO COOL CONTAINERS EXPOSED TO FIRE.DON'T ENTER FIRE
AREA WITHOUT PROPER PROTECT EQUIP,INCLUDING SCBA.
Unusual Fire/Explosion Hazard:AVOID SOURCES OF IGNITION, FLAME, STATIC
ELECTRICITY, HEAT OR ELECTRICAL SPARK.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL HEAT SOURCES, OPEN FLAMES, AND
OTHER IGNITION SOURCES. ABSORB WITH SOLID ABSORBENT. SHOVEL INTO
CONTAINERS. IF LARGE QUANTITIES ARE SPILLED, PERSONAL PROTECTIVE
EQUIPMENT MAY BE REQUIRED .
*Handling and Storage *
Handling and Storage Precautions:SECURE CLOSURES & KEEP CNTNRS UPRIGHT
(PREVENT LEAK). STORE IN COOL, VENTED AREA, AWAY FROM HEAT, SPARK,
FLAME. AVOID FREE FALL OF LIQ > FEW INCHES.
Other Precautions:DO NOT FLAME CUT, BRAZE OR WELD W/OUT NIOSH/MSHA
MECHAN FILTER RSPRTR/ADEQUATE VENT. IF WORKERS EXPOSED TO SPRAY
APPLIC/BLAST CLEANING, USE ENGINEERING/ADMIN CONTROLS (KEEP BELOW
TLV/PEL). SHIP PAINT IN METAL CNTNRS IN OUTSIDE CARTONS.
* Physical/Chemical Properties *
Vapor Density:3.8-4.9 *
Solubility in Water:INSOLUBLE *
Appearance and Odor:WATER WHITE AND CHARACTERISTIC PETROLEUM ODOR *
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:CO, NOX, LEAD, CHROMIUM FUME
* Disposal Considerations *
Waste Disposal Methods:DISPOSE AS PAINT WASTE IN ACCORDANCE WITH
FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF TLV OF PRODUCT OR ANY COMPONENT IS EXCEEDED,
A NIOSH/MSHA JOINTLY APPROVED AIR SUPPLIED RESPIRATOR IS ADVISED IN
ABSENCE OF PROPER ENVIRONMENTAL CONTROL OSHA REG ALSO PERMIT OTHER
NIOSH/MSHA RESPIR ATORS UNDER SPECIFIED CONDITIONS.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING AND BOOTS.
Work Hygienic Practices:KEEP WORK AREA CLEAN AND FREE FROM LEAKS AND
SPILLS. WASH HANDS THOROUGHLY W/SOAP & WATER BEFORE HANDLING FOOD &
DRINK.
Supplemental Safety and Health
ENGINEERING OR ADMINISTRATIVE CONTROLS SHOULD BE IMPLEMENTED TO REDUCE
EXPOSURE.
* Product Identification *
Product ID:ALKYD RESIN, VARNISH
* Composition/Information on Ingredients *
Ingred Name:2-BUTOXYETHANOL
Fraction by Wt: 2-7%
Fraction by Wt: <1%
Ingred Name:SURFACTANTS
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Effects of Overexposure:EYES:SEVERE IRRITATION,REDNESS,TEARING,BLURRED
VISION. SKIN:PROLONGED/REPEATED CONTACT CAN CAUSE MODERATE
IRRITATION,DEFATTING,DERMATITIS. BREATHING:EXCESSIVE INHALATION OF
VAPORS CAN CAUSE NASAL & RE SPIRATORY
IRRITATION,DIZZINESS,WEAKNESS,FATIGUE,NAUSEA,HEADACHE,POSSIBLE
UNCONSCIOUSNESS EVEN ASPHYXIATION.
Medical Cond Aggravated by Exposure:SWALLOWING CAN CAUSE
GASTROINTESTINAL IRRITATION NAUSEA,VOMITING AND DIARRHEA,
ASPIRATION OF MATERIAL INTO THE LUNGS CAN CAUSE CHEMICAL
PNEUMONITIS WHICH CAN BE FATAL.
* First Aid Measures *
First Aid:SKIN:THOROUGHLY WASH EXPOSED AREA W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING,LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.EYES:FLUSH W/LARGE AMOUNTS OF WATER,LIFTING EYELIDS OFTEN,GET
MEDICAL ATTENTIO N. SWALLOWING:DONOT INDUCE VOMITING,KEEP PERSON
WARM,QUIET & GET MEDICAL ATTN. INHALATION:IF AFFECTED,REMOVE PERSON
TO FRESH AIR. DIFFICULT BREATHING,GIVE OXYGEN.BREATHING
STOPPED,ARTIFICAL RESP.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1.0
Extinguishing Media:FOAM,CO2,DRY CHEMICAL.
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS WITH A FULL
FACEPIECE OPERATED IN PRESSURE DEMAND OR OTHER POSITIVE PRESSURE
MODE.
Unusual Fire/Explosion Hazard:NEVER USE NEAR OR AROUND WELDERS OR
CUTTING TORCHES,DRUM (EVEN EMPTY) BECAUSE PRODUCT (EVEN JUST
RESIDUE) CAN IGNITE EXPLOSIVELY.
* Accidental Release Measures *
Spill Release Procedures:SMALL SPILL:ABSORB LIQUID ON PAPER,
VERMICULITE, FLOOR ABSORBENT. LGE SPILL:ELIMINATE ALL IGNITION
SOURCES.PERSONS NOT WEARING PROTECTIVE EQUIPMENT ARE EXCLUDED FROM
AREA UNTIL CLEANUP COMPLETED.PREVE NT RUN. IF RUNOFF NOTIFY PROPER
AUTHORITIES.
*Handling and Storage *
Handling and Storage Precautions:RESPIRATORY PROTECTION: IF TLV
EXCEEDED A NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR IS
ADVISED.ENGR/ADMINISTRATIVE CONTROLS SHOULD BE IMPLEMENTED.
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTIED, SINCE EMPTY CONTAINERS RETAIN PRODUCT RESIDUES (VAPOR,
LIQUID, AND/OR SOLID)ALL HAZARD PRECAUTIONS GIVEN IN DATA SHEET
MUST BE OBSERVED.
* Physical/Chemical Properties *
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NIL
Appearance and Odor:TRANSLUCENT GREEN THIN LIQUID WITH A MILD SWEET
AROMATIC ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:KEEP AWAY FROM OPEN FLAMES,SPARKS AND
HEAT. DO NOT WELD NEAR OR AROUND PRODUCT.
Conditions to Avoid Polymerization:KEEP AWAY FROM OPEN FLAMES, SPARKS,
AND HEAT. DO NOT WELD NEAR OR AROUND PRODUCT.
* Disposal Considerations *
Waste Disposal Methods:DESTROY BY LIQUID INCINERATION, CONTAMINATED
ABSORBENT MAY BE DEPOSITED IN A LANDFILL IN ACCORDANCE WITH
LOCAL,STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED
Ventilation:LOCAL EXHAUST: ONLY IF NECESSARY. MECHANICAL: ACCEPTABLE.
Other Protective Equipment:IMPERMEABLE APRON
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:NON-HAZARDOUS FOR INGREDIENTS
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYE: IRRITATION. INHALATION:
IRRITATION, HEMORRHAGES IN STOMACH, LIVER, & KIDNEY.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN/EYE: IRRITATION. INHALATION: IRRITATION,
HEMORRHAGES IN STOMACH, LIVER, & KIDNEY.
* First Aid Measures *
INHALATION: GIVE CPR OR OXYGEN IF NEEDED. OBTAIN MEDICAL ATTENTION
IN ALL CASES.
* Fire Fighting Measures *
Flash Point:NON COMBUSTIBLE
Extinguishing Media:NONE REQUIRED
Unusual Fire/Explosion Hazard:NO EXPLOSION HAZARDS
* Accidental Release Measures *
Spill Release Procedures:FLUSH THE AREA W/LARGE AMOUNTS OF WATER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS & LABEL
CORROSIVE. AVOID CONTAMINATION OF FOOD.
* Physical/Chemical Properties *
Vapor Density:NIL
Evaporation Rate & Reference:(BU AC = 1): 0.3
Solubility in Water:MISCIBLE
Appearance and Odor:BRIGHT RED GEL W/MINT-LIKE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ALKALI METALS & ACID
Stability Condition to Avoid:HIGH HEAT TEMPERATURES
Hazardous Decomposition Products:TOXIC FUMES
* Disposal Considerations *
Waste Disposal Methods:FLUSH INTO AN INDUSTRIAL SEWER W/COPIOUS AMOUNTS
OF WATER.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NORMALLY REQUIRED. IF EMERGENCY OCCURS, USE
NIOSH/MSHA APPROVED RESPIRATOR OR SUPPLIED AIR RESPIRATOR OR SCBA,
Ventilation:USE ADEQUATE EXPLOSION-PROOF MECHANICAL VENTILATION.
Other Protective Equipment:PROTECTIVE CLOTHING, AS NEEDED, TO PREVENT
SKIN CONTACT.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
* Product Identification *
Product ID:AVIATION TURBINE FUEL JP-4
* Composition/Information on Ingredients *
Ingred Name:PARAFFINIC HYDROCARBON
Other REC Limits:NONE RECOMMENDED
Ingred Name:OLEFINIC HYDROCARBONS
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:AROMATIC HYDROCARBONS
Other REC Limits:NONE RECOMMENDED
Ingred Name:BENZENE (SARA III)
Fraction by Wt: 1%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:LONG TERM EXPOSURE MAY PRODUCE
FATIGUE, MUSCLE WEAKNESS, NAUSEA, VOMITING AND ABDOMINAL PAIN.
BENZENE, A GASOLINE COMPONENT, HAS BEEN LINKED TO BLOOD DISORDERS
IN MAN.
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:FATIGUE, MUSCLE WEAKNESS, NAUSEA, VOMITING AND
ABDOMINAL PAIN.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
SKIN: REMOVE CONTAMINATED CLOTHES. WASH WITH LARGE AMOUNTS OF SOAP
AND WATER. IF IRRITATION PERSISTS GET MEDICAL AID. INHALATION:
REMOVE TO FR ESH AIR. IF BREATHING HAS STOPPED; ADMINISTER
ARTIFICIAL RESPIRATION. GET MEDICAL AID. INGESTION: DO NOT INDUCE
VOMITING! GET MEDICAL AID.
* Fire Fighting Measures *
Extinguishing Media:FOAM, WATER SPRAY, DRY CHEMICAL, CARBON DIOXIDE
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE GEAR. DO NOT USE STRAIGHT WATER STREAM ON FIRE; IT
MAY CAUSE FIRE TO SCATTER/SPREAD.
Unusual Fire/Explosion Hazard:DO NOT ENTER CONFINED AREA WITHOUT PROPER
PROTECTIVE EQUIPMENT INCLUDING RESPIRATORY PROTECTION. VAPOR MAY
EXPLODE.
* Accidental Release Measures *
Spill Release Procedures:CONTAIN SPILL. ELIMINATE ALL SOURCES OF
IGNITION. REMOVE AS MUCH AS POSSIBLE BY VACUUMING OR SOAK UP WITH
ABSORBENT MATERIALS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL-VENTILATED
AREA AWAY FROM STRONG OXIDIZING AGENTS AND SOURCES OF IGNITION.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:F2
Vapor Pres:4 MM HG
Evaporation Rate & Reference:<1 (ETHER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR LIQUID; PETROLEUM ODOR
* Stability and Reactivity Data *
NONE SPECIFIED BY MANUFACTURER. HMIS: STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:KEEP AWAY FROM HEAT OR FLAME.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION MAY PRODUCE
CARBON MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. DO NOT FLUSH TO SURFACE WATER OR SANITARY
SEWER SYSTEM.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT
BUILD-UP OF VAPORS,TO KEEP AIR CONC BELOW TLV.
Other Protective Equipment:SAFETY SHOWER,EYE WASH
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING,ESPECIALLY
BEFORE EATING OR SMOKING.
Supplemental Safety and Health
N/K
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ETHYLENE GLYCOL (SARA III)
Fraction by Wt: 3%
Other REC Limits:
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TITANIUM DIOXIDE
Fraction by Wt: 2%
Other REC Limits:
Fraction by Wt: 3%
Other REC Limits:
OSHA PEL:
ACGIH TLV:
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS & SYMPTOMS OF OVEREXPOSURE .
Explanation of Carcinogenicity:
Effects of Overexposure:EYES*IRRITATION.INHAL:VOMITING,NAUSEA,DIZZINESS
&/OR LIGHTHEADNESS,RESPIRATORY IRRITATION,DIFFICULT
BREATHING.INGEST:MAY CAUSE NAUSEA,VOMITING,DIGESTIVE SYSTEM
PROBLEMS,DIFFICULT BREATHING.SKIN:IRRITA TION.SKIN CONTACT MAY
CAUSE NAUSEA,VOMITING,DIGESTIVE SYSTEM PROBLEMS,DIFFICULT
BREATHING.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR.SUPPORT BREATHING.GIVE
O*2/ARTIFICIAL RESPIRATION .SKIN:WASH OFF QUICKLY W/PLENTY OF
WATER,THEN SOAP & WATER.REMOVE CONTAMINATED CLOTHING.EYES:FLUSH
IMMEDIATELY W/LARGE AMOUNTS OF WATER,ESPECIALLY UNDER LIDSFOR @
MEDICAL TREATMENT IMMEDIATELY.
* Fire Fighting Measures *
Upper Limits:
Extinguishing Media:DRY CHEMICAL OR FOAM
Fire Fighting Procedures:WATER MAY BE USED TO COOL & PROTECT EXPOSED
CONTAINERS.HAZ DECOMP PRODUCTS:CO,CO*2.USE NIOSH/MSHA APPROVED SCBA
& FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY BURST IF EXPOSED TO
EXTREME HEAT OR FIRE.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION.VENTILATE
AREA.SMALL SPILLS MAY BE COLLECTED WITH ABSORBENT MATERIALS.
Neutralizing Agent:
*Handling and Storage *
TIGHTLY CLOSED & UPRIGHT WHEN NOT IN USE.KEEP OUT OF REACH OF
CHILDREN.
Other Precautions:USE ONLY WITH ADEQUATE VENTILATION.DO NOT TAKE
INTERNALLY.AVOID CONTACT WITH SKIN & EYES & BREATHING OF
VAPORS.AVOID BREATHING SANDING DUST.
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:
Decomp Temp:Decomp Text:
Vapor Pres:
Vapor Density:
Spec Gravity:
Evaporation Rate & Reference:
Solubility in Water:
Appearance and Odor:
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS
Stability Condition to Avoid:ELEVATED TEMPERATURES,CONTACT WITH
OXIDIZING AGENT.
Hazardous Decomposition Products:CARBON MONOXIDE,CARBON DIOXIDE
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE & LOCAL REGULATIONS .AVOID DISCHARGE TO NATURAL
WATERS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:THE USE OF A NIOSH APPROVED MASK FOR TOXIC DUST
IS REQUIRED IF CURED PRODUCT IS TO BE DRY SANDED OR GROUND.
Ventilation:USE WITH ADEQUATE VENTILATION. LOCAL EXHAUST IS RECOMMENDED
IN CONFINED AREAS.
Other Protective Equipment:PROTECTIVE EQUIPMENT TO COVER EXPOSED AREAS
Work Hygienic Practices:VENT CURING OVEN TO OUTDOORS. GOOD HOUSEKEEPING
IS REQUIRED. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
PRODUCT SHOULD BE USED WITH CAUTION UPON CURING.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:POLYOXYPROPYLENEDIAMINE (POPDA)
Other REC Limits:NONE SPECIFIED
Ingred Name:BISPHENOL A EPOXY RESIN
Other REC Limits:NONE SPECIFIED
Ingred Name:THIS PRODUCT CONTAINS A SMALL PERCENTAGE OF AMORPHOUS
SILICA WHICH IS FULLY WETTED IN THE UNCURED ADHESIVE. THE USE OF*
Other REC Limits:NONE SPECIFIED
Ingred Name:*A NIOSH APPROVED MASK FOR TOXIC DUST IS REQUIRED IF THE
CURED PRODUCT IS TO BE DRY SANDED OR GROUND BECAUSE OF THE **
Other REC Limits:NONE SPECIFIED
Ingred Name:**PRESENCE OF CRYSTALLINE SILICA DUST (AS IMPURITY) WHICH
IS CONCIDERED A PROBABLE HUMAN CARCINOGEN BY IARC.
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALED: VAPOR MAY BE HARMFUL IF
INHALED. CONTACT WITH SKIN: CORROSIVE. CAN CAUSE SKIN BURNS AND
BLISTERING. CONTACT WITH EYES: MAY CAUSE SEVERE EYE IRRITATION.
SWALLOWED: HARMFUL IF SWALLOWED. CHRONI C: PROLONGED OR REPEATED
CONTACT WITH SKIN CAN CAUSE IRRITATION, DERMATITIS & SENSITIZATION.
* First Aid Measures *
MEDICAL ATTENTION. SKIN CONTACT: WASH IMMEDIATELY WITH SOAP AND
WATER. IF IRRITATION PERSISTS, SEEK MEDICAL ATTENTION IMMEDIATELY.
INHALED: REMOVE TO FRESH AIR IMMEDIATELY. INGESTION: SEEK MEDICAL
ATTENTION IMMEDIATELY AND SHOW INSERT CARD.
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:DECOMPOSITION AND COMBUSTION PRODUCTS CAN
BE TOXIC.
* Accidental Release Measures *
Spill Release Procedures:WIPE UP WITH SOLVENT SATURATED TOWELING AND
COLLECT IN AN APPROPRIATE CONTAINER FOR DISPOSAL. USE DISPOSABLE
*Handling and Storage *
Handling and Storage Precautions:STORE FROZEN AT ALL TIMES.
Other Precautions:AVOID CONTACT WITH SKIN, EYES AND CLOTHING. AVOID
INHALATION OF VAPORS.
* Physical/Chemical Properties *
Vapor Pres:1
Spec Gravity:2.1
Solubility in Water:NIL
Appearance and Odor:OPAQUE AMBER PASTE
Percent Volatiles by Volume:NIL
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS AND STRONG MINERAL OR LEWIS ACID.
Stability Condition to Avoid:HEAT PRIOR TO CURE.
Hazardous Decomposition Products:CARBON MONOXIDE, AMMONIA, ALDEHYDES
AND ACIDS ON INCOMPLETE COMBUSTION.
Conditions to Avoid Polymerization:EXCESSIVE HEAT. IF NOT USED FOR THIN
BOND LINE APPLIC, VIOLENT CHEM REACTION CAN RESULT. VENT CURING
OVEN TO OUTDOORS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN APPROVED CHEMICAL DISPOSAL AREA OR IN
A MANNER WHICH COMPLIES WITH ALL LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE RESP PROTECTION IF NECESSARY
Ventilation:LOCAL EXHAUST RECOMMENDED
Supplemental Safety and Health
NK
* Product Identification *
Product ID:SILICON ELASTOMER PRIMER
Kit Part:Y
Preparer's Name:GARY HARTLEDGE
* Composition/Information on Ingredients *
Fraction by Wt: 2.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHYLENE GLYCOL METHYL ETHER
Fraction by Wt: 3%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:5 PPM
Ingred Name:TETRA PROPYL ORTHO SILICATE
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: 7%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 PPM
Ingred Name:TETRABUTYL TITANATE
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NAPHTHA, LIGHT ALIPHATIC (PETROLEUM) (THIS MATERIAL
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NE
Ingred Name:TETRA (2-METHOXYFETHOXY) SILANE
Fraction by Wt: 2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 PPM
ACGIH TLV:NE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITATION, REDNESS, SWELLING,
CORNEAL INJURY, PAIN, TEARING. SKIN: IRRITATION, MILD BURNS. SKIN
ABSORBTION: INTERNAL INJURY. INHAL: DROWSINESS, IRRITATION. INJURES
BLOD, LUNGS, LIVER, KIDNEYS, N S, REPRO ORGANS, BRAIN. INGESTION:
VOMIT(SERIOUS LUNG INJURY. LARGE AMOUNTS WILL CAUSE SERIOUS INJURY.
* Fire Fighting Measures *
Flash Point Method:CC
Autoignition Temp:Autoignition Temp Text:NE
Extinguishing Media:WATER FOG OR SPRAY, CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:SCUBA, PROTECTIVE CLOTHING, COOL WITH WATER
SPRAY. EVAC AREA.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR, MAY TRAVEL
TO IGNIT SOURCES. STATIC ELECTRICITY MAY ACCUMULATE.
* Accidental Release Measures *
Spill Release Procedures:REMOVE IGNIT, USE NON SPARKING TOOLS/STORE
CLEAN UP MATLS ININ COVERED CONT. EVAC IF APPROPRIATE. SOAK UP
W/ABSORBANT. MOP SLIPPERY SURFACES. DIKE LARGE SPILLS. REPORT IF
REQUIRED.
*Handling and Storage *
Handling and Storage Precautions:BOND/GROUND CONTAINER WHEN
TRANSFERING. KEEP CONTAINERS CLOSED AND WAY FROM IGNIT SOURCES,
WATER AND MOISTURE
* Physical/Chemical Properties *
Boiling Pt:B.P. Text:NA
Vapor Pres:NE
Viscosity:1CST
Evaporation Rate & Reference:NE
Solubility in Water:NONE
Appearance and Odor:COLORLESS LIQUID W/SOLVENT ODOR
Percent Volatiles by Volume:NE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
INCOMPATIBILITY WITH OXIDIZING MATERIAL
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CARBON OXIDES, TRACES OF CARBON
COMPOUNDS, SILICONE DIOXIDE, METAL OXIDES, AND FORMALDEHYDE
* Disposal Considerations *
Waste Disposal Methods:FOLLOW FEDERAL, STATE AND LOCAL REGULATIONS
| 1 | eyes_protection_mandatory |
Control Measures
*
*
Preparer Co. when other than Responsible Party Co.
*
Assigned Ind: Y
*
Contractor Summary
*
*
Item Description Information
*
Item Manager: S9G
Item Name: LUBRICANT
Specification Number: UNKNOWN
Unit of Issue: CN
UI Container Qty: 0
Type of Container: CAN
*
Ingredients
*
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 5 MG/M3 OIL MIST
ACGIH TLV: 5 MG/M3 OIL MIST
------------------------------
% Wt: 3-6
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
-----------------------------
% Wt: 2-3
Other REC Limits: NONE RECOMMENDED
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHALATION MAY CAUSE HEADACHE, NAUSEA, DIZZINESS &
ANESTHETIC EFFECTS. EXPOSURE MAY CAUSE EYE IRRITATION. INGESTION IS NOT A
LIKELY ROUTE OF EXPOSURE. ASPIRATED PRODUCT MAY CAUSE SEVERE PULMONARY INJU
RY. CHRONIC: PROLONGED OR REPEATED SKINCONTACT MAY CAUSE DRYING OF SKIN.
Explanation Of Carcinogenicity: NO INGREDIENT OF A CONCENTRATION OF 0.1% OR
GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Signs And Symptions Of Overexposure: INHALED-HEADACHE, NAUSEA, DIZZINESS,
ANESTHIC EFFECTS. EYES-IRRITATION. SKIN-DRYNESS. INGESTED-NONE STATED;
ASPIRATION-PULMONARY INJURY.
Medical Cond Aggravated By Exposure: NONE FROM NORMAL EXPOSURE.
WITH MILD SOAP & WATER, APPLY MEDICATED CREAM. INHALED-REMOVE TO FRESH
AIR. CONTACT PHYSICIAN. INGESTED-CONTAINS PETROLEUM HYDROCARBO NS. DO NOT
INDUCE VOMITING! CONTACT PHYSICIAN IMMEDIATELY!
*
Handling and Disposal
*
Spill Release Procedures: VENTILATE AREA. ELIMINATE ALL SOURCES OF IGNITION.
REMOVE LEAKING CONTAINER; TRANSFER REMAINING PRODUCT TO DIFFERENT CONTAINER.
KEEP OUT OF SEWERS/WATERWAYS. USING APPROPRIATE SAFETY EQUIPMENT, MOP UP OR
SOAK UP WITH ABSORBENT (SAND, CLAY,ETC).
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS FOR PETROLEUM DISTILLATE. RCRA HAZWASTE:NOT APPLICABLE, CERCLA
RQ:NONE, SARA TITLE III CHEMICALS:NONE.
FROM IGNITION SOURCES. AVOID BREATHING VAPORS.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
*
Fire and Explosion Hazard Information
*
Flash Point Method: SCC
Lower Limits: 1
Upper Limits: 6
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: DO NOT USE WATER. TREAT AS COMBUSTIBLE PETROLEUM
DISTILLATES. DLA-: WEAR SCBA AND FULL TURN-OUT GEAR.
Unusual Fire/Explosion Hazard: INTENSIVE HEAT CREATED BY FIRE WILL CAUSE
AEROSOLS TO BURST.
*
*
Respiratory Protection: NONE REQUIRED IF GOOD VENTILATION IS MAINTAINED. FOR
ENCLOSED AREAS USE NIOSH APPROVED ORGANIC VAPOR CARTRIDGE RESPIRATOR OR
SELF-CONTAINED BREATHING APPARATUS.
Ventilation: USE ADEQUATE MECHANICAL VENTILATION OR LOCAL EXHAUST TO MAINTAIN
EXPOSURE BELOW TLV(S).
Other Protective Equipment: NONE. DLA-: EYE WASH STATION & WASHING FACILITIES.
Work Hygienic Practices: WASH HANDS AFTER HANDLING AND BEFORE EATING, DRINKING,
OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
*
Physical/Chemical Properties
*
HCC: V4
M.P/F.P Text: UNKNOWN
Decomp Text: UNKNOWN
Vapor Density: 4.7
Viscosity: UNKNOWN
Solubility in Water: NIL
Appearance and Odor: CLEAR, THIN LIQUID WITH SWEET ODOR.
Corrosion Rate: UNKNOWN
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: AVOID SPARKS OR OPEN FLAMES. SEE HANDLING &
STORAGE PRECAUTIONS.
Materials To Avoid: STRONG OXIDIZING MATERIALS.
Hazardous Decomposition Products: THERMAL DECOMPOSITION MAY YIELD CARBON
MONOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: WILL NOT OCCUR.
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
Transportation Information
*
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: CN
Container QTY: 0
Type Of Container: CAN
*
Detail DOT Information
*
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail IMO Information
*
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
*
Detail IATA Information
*
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail AFI Information
*
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
HAZCOM Label
*
Assigned IND: Y
Company Name: LPS LABORATORIES, INC
Label Required IND: Y
Status Code: C
Origination Code: F
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE! INHALATION MAY CAUSE HEADACHE, NAUSEA,
DIZZINESS & ANESTHETIC EFFECTS. EXPOSURE MAY CAUSE EYE IRRITATION.
INGESTION IS NOT A LIKELY ROUTE OF EXPOSURE. ASPIRATED PRODUCT MAY CAUSE
SEVERE P ULMONARY INJURY. PROLONGED OR REPEATED SKIN CONTACT MAY CAUSE DRYING
OF SKIN. TARGET ORGANS: CNS, LUNGS, SKIN. FIRST AID: EYES-FLUSH WITH WATER
APPLY MEDICATED CREAM. INHALED-REMOVE TO FRESH AIR. CONTACT PHYSICIAN.
INGESTED-CONTAINS PETROLEUM HYDROCARBONS. DO NOT INDUCE VOMITING! CONTACT
PHYSICIAN IMMEDIATELY!
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:PROVIDE GOOD VENTILATION TO MAINTAIN VAPOR CONCENTRATION
Supplemental Safety and Health
NK
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
Ozone Depleting Chemical:1
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
Fraction by Wt: 4-9%
Ingred Name:AMINE
Fraction by Wt: <3%
ACGIH TLV:TOXIC
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Effects of Overexposure:HEADACHE AND NAUSEA
* First Aid Measures *
First Aid:SKIN: FLUSH WITH WATER. EYE: FLUSH WITH WATER. SEEK MEDICAL
ATTENTION. INHALATION: REMOVE TO FRESH AIR, IF SYMPTOMS PERSISTS,
SEEK MEDICAL ATTENTION. AND INGESTION: DO NOT INDUCE VOMITING. SEEK
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:DNA
Upper Limits:DNA
Extinguishing Media:FOAM, DRY CHEMICAL, CO2
Fire Fighting Procedures:SELF CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING SHOULD BE WORN IN FIGHTING FIRES INVOLVING
CHEMICALS
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:1-ALLOW SOLVENT TO EVAPORATE WITH GOOD
VENTILATIONS. 2-SOAK UP RESIDUE WITH INERT MATERIAL. 3-STORE IN
CLOSED CONTAINER UNTIL DISPOSAL
*Handling and Storage *
SKIN CONTACT AND AVOID PROLONGED BREATHING OF THE VAPORS
* Physical/Chemical Properties *
Vapor Density:4.5
Solubility in Water:NONE
Appearance and Odor:YELLOW LIQUID, CHLOROFORM LIKE (SHARP)
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
WILL ATTACK PAINT ENAMEL, ETC.
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:INCINERATE OR BURY. FOLLOW LOCAL AND FEDERAL
REGULATIONS
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED
Ventilation:MECHANICAL
Other Protective Equipment:EYEWASH STATIONS, SAFETY SHOWERS
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:BORIC ACID, ORTHOBORIC ACID
Fraction by Wt: 1.6%
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: IRRITATION. INGESTION:
NAUSEA, VOMITING. INHALATION: HEADACHE, COUGHING, DIZZINESS &
DIFFICULTY IN BREATHING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN/EYES: IRRITATION. INGESTION: NAUSEA.
INHALATION: COUGHING, DIZZINESS, & DIFFICULTY IN BREATHING.
* First Aid Measures *
VOMITING.
* Fire Fighting Measures *
Extinguishing Media:APPROPRIATE FOR SURROUNDING FIRE.
* Accidental Release Measures *
Spill Release Procedures:WIPE UP LIQUID.
*Handling and Storage *
Handling and Storage Precautions:DON'T WEAR CONTACT LENSES.
* Physical/Chemical Properties *
Solubility in Water:MODERATE
Appearance and Odor:COLORLESS ODORLESS SOLID.
Percent Volatiles by Volume:0%
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
POTASSIUM METAL, WATER
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:A RESPIRATOR APPROVED BY NIOSH WITH FILTER
CARTRIDGES APPROVED FOR DUST/FUMES/MISTS SHOULD BE WORN AT ALL
TIMES DURING THERMAL SPRAY PROCESS TO PROTECT OPERATOR. RESPIRATORS
MAY ALSO BE WORN WHEN PROD UCT HANDLING GENERATES DUST.
Ventilation:USE ONLY WITH ADEQUATE LOCAL EXHAUST VENTILATION.
Other Protective Equipment:HEARING PROTECTION. ALUMINIZED APRONS DURING
PROCESSING & OTHER APPROPRIATE PROTECTIVE CLOTHING.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
EYE WASH STATIONS ARE RECOMMENDED.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:NICKEL (SARA III)
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
Ingred Name:ALUMINUM (SARA III)
Fraction by Wt: 5% %
Other REC Limits:NONE RECOMMENDED
Ingred Name:ORGANIC BINDER
Fraction by Wt: 1% %
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION MAY CAUSE PNEUMOCONIOSIS,
CANCERS OF THE LUNG AND NASAL SINUSES. PULMONARY, SKIN AND EYE
IRRITANT DUE TO ABRASIVE ACTION. MAY CAUSE DERMATITIS. MAY CAUSE
RESPIRATORY TRACT IRRITATION.
Explanation of Carcinogenicity:CONTAINS NICKEL A POSSIBLE HUMAN
CARCINOGEN.
Effects of Overexposure:MAY CAUSE EYE IRRITATION, SKIN IRRITATION,
DERMATITIS, RESPIRATORY TRACT IRRITATION, PNEUMOCONIOSIS, POSSIBLE
LUNG AND/OR NASAL SINUS CANCER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:EYES: FLUSH WITH SUFFICIENT AMOUNTS OF WATER. IF IRRITATION
PERSISTS, CONSULT A PHYSICIAN. SKIN: IF IRRITATION OCCURS, WASH
WITH SOAP AND WATER TO REMOVE POWDER. INHALATION: EXPOSE TO FRESH
AIR. CONSU LT PHYSICIAN IF IRRITATION OR RESPIRATORY DISTRESS
PERSISTS. INGESTION: CONSULT A PHYSICIAN.
* Fire Fighting Measures *
Flash Point:NONE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:USE CLASS D FIRE EXTINGUISHER.
Fire Fighting Procedures:TREAT AS A METALLIC FIRE.
Unusual Fire/Explosion Hazard:FINE METAL DUSTS ARE FLAMMABLE AND MAY
EXPLODE WHEN EXPOSED TO HEAT, FLAME OR OXIDIZERS. ALUMINUM IS A
FLAMMABLE SOLID, DON'T EXPOSE TO WATER OR MOISTURE.
* Accidental Release Measures *
Spill Release Procedures:VACUUM LOOSE POWDER ONLY WITH VACUUMS EQUIPPED
WITH HEPA FILTRATION. VACUUMS APPROPRIATE FOR USE WITH ALUMINUM
METALLIC SHOULD BE UTILIZED. WIPE THE AREA CLEAN. DO NOT USE WATER
FOR CLEAN UP OPERATION S. DO NOT SWEEP. AVOID GENERATING AIRBORNE
DUST.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM INCOMPATIBLES. STORE
PRODUCT CONTAINERS IN WELL VENTILATED, CLEAN, COOL AND DRY AREA.
AVOID PHYSICAL DAMAGE.
Other Precautions:AVOID CONTACT OF MATERIAL WITH WATER OR OXIDIZERS. DO
NOT INGEST. AVOID INHALATION, PROLONGED OR REPEATED SKIN CONTACT OR
CONTACT WITH EYES.
* Physical/Chemical Properties *
HCC:N1
Boiling Pt:B.P. Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:NOT GIVEN
Spec Gravity:3.7
Solubility in Water:NEGATIVE
Appearance and Odor:POWDER, NO ODOR
Percent Volatiles by Volume:NIL
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, SULFUR, NI(NO3)2, COMBUSTIBLES.
Stability Condition to Avoid:WATER, MOISTURE, HEAT, FLAME.
Hazardous Decomposition Products:OZONE AND NITRIC OXIDE ARE FORMED BY
PLASMA FLAME. CARBON MONOXIDE, CARBON DIOXIDE, NITROGEN OXIDES,
SULFUR OXIDES.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL,
STATE, AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN.
Ventilation:GENERAL DILUTION/LOCAL EXHAUST WITH EXPLOSION PROOF MOTORS
Other Protective Equipment:NORMAL PROTECTIVE CLOTHING.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:NAPHTA (PETROLEUM SPIRITS OR BENZIN)
Fraction by Wt: <5%
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
Ingred Name:N-BUTYL ALCOHOL (SARA III)
Fraction by Wt: <5%
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
Fraction by Wt: <0.5%
Ingred Name:2,4,6 - TRI(DIMETHYLAMINOMETHYL)PHENOL
Fraction by Wt: <5%
* Hazards Identification *
Effects of Overexposure:SKIN/EYE: IRRITATION. INHALATION: IRRITATION OF
RESPIRATORY TRACT,HEADACHE,NAUSEA,DIZZINESS
* First Aid Measures *
WATER,REMOVE CONTAMINATED CLOTHING. INHALATION: REMOVE TO FRESH
AIR. INGESTION: CALL PHYSICIAN IMMEDIATELY.
* Fire Fighting Measures *
Extinguishing Media:CO*2,DRY CHEMICAL,FOAM
Fire Fighting Procedures:SELF-CONT BREATH APP,WATER FOG TO COOL EXPOSED
CONTAINERS
Unusual Fire/Explosion Hazard:DUE TO PRESSURE BUILD-UP,CLOSED
CONTAINERS EXPOSED TO HEAT MAY EXPLODE.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
BREATHING VAPORS. VENTILATE AREA. CONTAIN SPILLED MATERIAL AND
REMOVE WITH INERT ABSORBENT AND NON-SPARKING TOOLS. STORE IN CLOSED
CONTAINER UNTIL PROPERLY DISPOS ED OF.
*Handling and Storage *
FIRE OR OPEN FLAME. STORE LARGE QUANTITIES IN BUILDING DESIGNED TO
Other Precautions:CLOSE CONTAINER AFTER USE. DO NOT REUSE EMPTY
CONTAINERS.
* Physical/Chemical Properties *
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS,RUBBER SOFTENS
Hazardous Decomposition Products:CO,CO*2,OXIDES OF NITROGEN
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL,STATE AND
FEDERAL REGULATIONS. INCINERATE ONLY IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
NECESSARY.
Ventilation:USE ADEQUATE VENTILATION TO KEEP AIRBORNE CONCENTRATIONS
LOW.
Other Protective Equipment:ANSI APPRVD EMER EYE WASH & DELUGE SHOWER .
WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
MATLS TO AVOID: AMMONIUM HYDROXIDE, AZIRIDINE, CALCIUM CARBIDE,
ETHANOL, ETHANOL & NITRIC ACID., ETHYLENEIMINE, 1-BROMO-2-PROPYNE,
CHARCOAL, CHLORINE TRIFLUORIDE, ETHYLENENE OXIDE, ETHYLENE
HYDROPEROX IDE, HYDROGEN PEROXIDE, MAGNESIUM ARSENIC/CUPROUS
ACETYLIDE. EFTS OF OVEREXP: & MUC MEMB. THE CNDTN DEVELOPS (ING 2)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SILVER (I) NITRATE (1:1); (NITRIC ACID, SILVER(1+) SALT
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
NO OTHER SYMPS/PHYSICAL IMPAIRMENT ASSOC W/ARGYRIA. (ING 3)
Ingred Name:ING 2:CHRONIC SKIN CONTACT MAY CAUSE LOCAL ARGYRIA, A
PERMANENT DISCOLORATION OF THE SKIN.
Ingred Name:FIRST AID PROC:TO AN UNCONSCIOUS PERSON. GET MED AID IMMED.
INHAL:GET MED AID IMMED. REMOVE FROM EXPOS TO FRESH (ING 5)
Ingred Name:ING 4:AIR IMMEDIATELY. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN. (ING 6)
Ingred Name:ING 5:NOTES TO PHYSICIAN: TREAT SYMPTOMATICALLY AND
SUPPORTIVELY.
Ingred Name:EYE PROT: AND FULL LENGTH FACESHIELD .
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE:CNTCT W/EYES MAY CAUSE SEV
IRRIT, & POSS EYE BURNS. SKIN:CAUSES SEV SKIN IRRIT. CAUSES SKIN
BURNS. INGEST:HARMFUL IF SWALLOWED. MAY CAUSE SEV GI TRACT IRRIT
W/NAUS; VOMIT & POSS BURNS. LETH AL DOSE FOR HUMANS IS 2 GRAMS.
INHAL:CAUSE SEV IRRIT OF UPPER RESP TRACT W/COUGHING, BURNS, BRTHG
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:DFCLTY, & POSS COMA. CHRONIC:MAY CAUSE
METHEMOGLOBINEMIA, WHICH IS CHARACT BY CHOCOLATE-BROWN COLORED
BLOOD, HDCH, WEAK, DIZZ, BRTH SHORTNESS, CYANOSIS, RAPID HEART
RATE, UNCONSCIOUSNESS & PO SS DEATH. CHRONIC INHAL/INGEST MAY CAUSE
"ARGYRIA", WHICH IS CHARACTERIZED BY BLUE-GRAY PIGMENTATION OF THE
SKIN(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
LIFTING THE UPPER & LOWER LIDS. GET MED AID IMMED. DO NOT ALLOW
VICTIM TO RUB/KEEP EYES CLSD. SKIN: GET MED AID IMMED. IMMED FLUSH
CLTHGS & SHOES. INGEST: DO NOT INDUCE VOMIT. IF VOMIT CONSCIOUS &
ALERT, GIVE 2-4 CUPFULS OF MILK/H*2O. NEVER GIVE ANYTHING BY MOUTH
(ING 4)
* Fire Fighting Measures *
Extinguishing Media:SUBSTANCE IS NONCOMBUSTIBLE; USE AGENT MOST
APPROPRIATE TO EXTINGUISH SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . STRONG OXIDIZER. CONTACT WITH COMBUSTIBLE MATERIALS MAY
CAUSE A FIRE.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:VACUUM OR SWEEP UP MATERIAL AND PLACE INTO A
SUITABLE DISPOSAL CONTAINER. AVOID GENERATING DUSTY CONDITIONS.
REMOVE ALL SOURCES OF IGNITION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM SOURCES OF IGNITION. DO
NOT STORE NEAR COMBUSTIBLE MATERIALS. STORE IN A TIGHTLY CLOSED
CONTAINER.
Other Precautions:STORE IN A COOL, DRY, WELL-VENTILATED AREA AWAY FROM
INCOMPATIBLE SUBSTANCES. USE W/ADEQUATE VENT. DO NOT GET IN EYES,
ON SKIN, OR ON CLOTHING. KEEP CONTAINER TIGHTLY CLOSED. DO NOT
INGEST/INHALE. DO NOT STORE NEAR COMBUSTIBLE MATERIALS.
* Physical/Chemical Properties *
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:SOLUBLE IN WATER
Appearance and Odor:WHITE OR COLORLESS CRYSTALS; ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
REACTS DANGEROUSLY (EXPLOSION, IGNITION, PROPELLANT TYPE BURNING,
FORMATION EXPLOSIVE PRODUCTS) W/ACETYLENE, (SUPDAT)
Stability Condition to Avoid:INCOMPATIBLE MATERIALS, COMBUSTIBLE
MATERIALS, REDUCING AGENTS.
Hazardous Decomposition Products:NITROGEN OXIDES, SILVER OXIDES.
Conditions to Avoid Polymerization:HAS NOT BEEN REPORTED.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE, AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED FUME RESPIRATOR OR AIR
SUPPLIED RESPIRATOR IN CONFINED SPACES OR WHERE VENTILATION DOES
NOT KEEP EXPOSURE BELOW TLV.
Ventilation:LOCAL EXHAUST TO MAINTAIN BELOW TLV.
Other Protective Equipment:CLOTHING APPROPRIATE FOR SOLDERING-EYE BATH
STATION NEAR SOLDERING.
Work Hygienic Practices:IF HANDLED WITH BARE HANDS,WASH THOROUGHLY
AFTER HANDLING.
Supplemental Safety and Health
PRE-EXISTING SKIN DISORDERS,PULMONARY INSUFFICIENCIES,LIVER &
KIDNEY FUNCTIONS.DO NOT ALLOW PREG NANT WOMEN IN SOLDERING AREA.
* Product Identification *
Preparer's Name:TED VAN DER MOLEN
* Composition/Information on Ingredients *
Ingred Name:TIN
OSHA PEL:2 MG/M3
Ingred Name:ANTIMONY (SARA III)
OSHA PEL:0.5 MG/M3
Ingred Name:LEAD (SARA III)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ROSIN
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Health Hazards Acute and
Chronic:EYES:IRRITATION,BURNS;SKIN:BURNS;INHALATION;IRRITATION OF
MUCOUS MEMBRANES,SWEETISH METALLIC TASTE,BURNING IN
MOUTH;INGESTION:N/R. CHRONIC HAZARD:ANOREXIA "LEAD LINE" ON GUM
MARGIN,NAUSEA,SEVERE ABDOM INAL PAIN,VISUAL DISTURBANCE,PARALYSIS.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PULMONARY INSUFFICIENCIES &
PRE-EXISTING EYE DISORDERS.
* First Aid Measures *
First Aid:EYES:WASH WITH LARGE AMOUNTS OF WATER & APPLY SOOTHING
SOLUTION;SKIN:APPLY BURN OINTMENT;INHALATION:REMOVE TO FRESH AIR.IF
DISCOMFORT PERSISTS,SEE DOCTOR.
* Fire Fighting Measures *
Extinguishing Media:ANY MEDIA APPROPRIATE FOR SURROUNDING FIRE.AVOID
USING WATER ON MOLTEN ALLOY.IT GENERATES MUCH STEAM WITH METAL
SPLASHNG
SCBA FOR PROTECTION AGAINST LEAD FUMES.
Unusual Fire/Explosion Hazard:WELDING ARCS & SPARKS CAN IGNITE
COMBUSTIBLE PRODUCTS.
* Accidental Release Measures *
Spill Release Procedures:FINE DUST SHOULD BE VACUUMED.
*Handling and Storage *
Other Precautions:TRAIN WELDER TO KEEP HIS HEAD OUT OF THE FUMES.
MONITOR AIR TO ENSURE ACCEPTABLE EXPOSURES.AVOID ELECTRICAL SHOCK
BY MAINTAING DRY WORK AREA.
* Physical/Chemical Properties *
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:SEE SUPPL
Spec Gravity:SEE SUPPL DATA
Solubility in Water:INSOLUBLE
Appearance and Odor:FLUX:AMBER SOLID,NO ODOR.ALLOY:SILVER GREY SOLID.NO
ODOR
Percent Volatiles by Volume:NONE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Hazardous Decomposition Products:FUMES & PARTICULATES OF METALS & METAL
OXIDES,CO,CO*2,OXIDES OF NITROGEN,VARIOUS HYDROCARBONS,O*3.
* Disposal Considerations *
Waste Disposal Methods:RECYCLING. DISPOSE OF RESIDUE FROM WORK AREA OR
FILTERS IAW FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE
Ventilation:NONE
Other Protective Equipment:NONE
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:PETROLEUM HYDROCARBON
* Hazards Identification *
Effects of Overexposure:SKIN
CONTACT:DERMATITIS;INHALATION:DIZZINESS,HEADACHE,NAUSEA.
* First Aid Measures *
First Aid:INHAL:RMV TO FRESH AIR. IF NOT BRTHNG GIVE CPR; IF BRTHNG
DIFF GIVE OXYGEN. EYE:IMMED FLUSH W/PLENTY OF WATER. SKIN:WASH
W/SOAP & WATER. RMV CONTAM CLTHG & SHOES. INGEST:DO NOT INDUCE
VOMIT. NOTHG BY MOUTH IF UNCONSC. GET MEDICAL ATTN.
* Fire Fighting Measures *
Extinguishing Media:DRY CHEM,CO*2.WTR SPRAY,FOAM
Fire Fighting Procedures:AVOID USE OF WATER.
Unusual Fire/Explosion Hazard:DENSE SMOKE.FIRE FIGHTERS SHOULD WEAR
SCBA.
* Accidental Release Measures *
Spill Release Procedures:ABSORB WITH AN INERT ABSORBENT SUCH AS
SAND,CLAY OR VERMICULITE,AND SWEEP UP.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT & FLAMES.
* Physical/Chemical Properties *
HCC:N1
Vapor Pres:<1.
Vapor Density:<0.1
Evaporation Rate & Reference:<0.1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OILY LIQ,NO OBJECTIONABLE ODOR.
* Stability and Reactivity Data *
STRG OXID AGTS LIKE NITRIC AC.,HYDROGEN PEROX.,CHROMIC AC.
Stability Condition to Avoid:MFR DID NOT SPECIFY.
Hazardous Decomposition Products:CO,SO*2,NO*X.
Conditions to Avoid Polymerization:MFR DID NOT SPECIFY.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW LOCAL,STATE & FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH APPROVED ORGANIC RESPIRATOR IF TWA/TLV
LIMITS ARE EXCEEDED.
Ventilation:USE LOCAL EXHAUST TO MAINTAIN LEVELS BELOW TWA LIMITS. USE
NON SPARKING EQUIPMENT.
Other Protective Equipment:NONE
Work Hygienic Practices:MFR:?. HMIS:USE GOOD CHEMICAL HYGIENE
PRACTICES. AVOID CONTACT IF AT ALL POSSIBLE. WASH THOROUGHLY AFTER
HANDLING.
Supplemental Safety and Health
NONE
* Product Identification *
CAGE:EMCOR
CAGE:EMCOR
* Composition/Information on Ingredients *
Ingred Name:ETHYL ALCOHOL (ETHANOL)
Other REC Limits: SPECIFIED BY M.
Other REC Limits: SPECIFIED BY M.
Ingred Name:VM&P NAPHTHA (LIGROINE)
Other REC Limits: SPECIFIED BY M.
Ingred Name:2-BUTOXYETHANOL
Ingred Name:PETROLEUM MINERAL OIL
Ingred Name:MOLYBDENUM DISULFIDE
OSHA PEL:0.5 MG (SB)/M3
Fraction by Wt: TRACE
Fraction by Wt: TRACE
Other REC Limits: RECOMMENDED
OSHA PEL:S, 5 PPM
Fraction by Wt: TRACE
Other REC Limits: RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES:CAN CAUSE IRRITATION, REDNESS,
BLURRED VISION. SKIN:PROLONGED CONTACT CAN CAUSE IRRITATION,
DERMATITIS. INHALATION:CAN CAUSE IRRITATION, DIZZINESS, NAUSEA,
FATIGUE, HEADACHE, & UNCONSCIOUSNESS OR ASPHYXIATION.
INGESTION:CAN CAUSE G/I IRRITATION, NAUSEA, VOMITING & DIARRHEA.
Explanation of Carcinogenicity:MFR LISTS FORMALDEHYDE, ISOPROPYL
ALCOHOL & ANTIMONY AS CARCINOGENS. SEE INDIVIDUAL REPORTS FOR
DETAILS.
Effects of Overexposure:EYE:IRRITATION, REDNESS, BLURRED VISION.
SKIN:PROLONGED CONTACT-IRRITATION, DERMATITIS.
INHALATION:IRRITATION, DIZZINESS, NAUSEA, FATIGUE, HEADACHE, &
UNCONSCIOUSNESS OR ASPHYXIATION. INGESTION:G/I IR RITATION, NAUSEA,
VOMITING & DIARRHEA.
Medical Cond Aggravated by Exposure:MFR GAVE NO INFORMATION ON MSDS.
* First Aid Measures *
First Aid:SKIN:WASH W/SOAP & WATER. EYE:FLUSH W/ COPIOUS AMOUNTS OF
WATER & GET IMMEDIATE MEDICAL ATTENTION. INHALATION: REMOVE TO
FRESH AIR. AID OR RESTORE BREATHING AS NECESSARY. INGESTION:DO NOT
INDUCE VOMIT ING, KEEP WARM, GET IMMEDIATE MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1.0
Upper Limits:N/DETERMINED
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL OR HALON
Fire Fighting Procedures:
Unusual Fire/Explosion Hazard:
* Accidental Release Measures *
Spill Release Procedures:CLEAN SPILL W/ABSORBENT MATERIAL. ELIMINATE
EXCEEDED.
Neutralizing Agent:MFR GAVE NO INFORMATION ON MSDS.
*Handling and Storage *
Handling and Storage Precautions:PROTECT FROM PHYSICAL DAMAGE. STORE IN
A COOL, DRY, VENTILATED AREA, AWAY FROM ACIDS, ALKALIS, OPEN
FLAMES.
Other Precautions:FLAMMABLE. DO NOT SPRAY NEAR OPEN FLAME.
* Physical/Chemical Properties *
HCC:F3
NRC/State Lic Num:
Boiling Pt:B.P. Text:N/AVAILABLE
Melt/Freeze Pt:M.P/F.P Text:N/AVAIL
Vapor Pres:N/AVAIL.
Vapor Density:>1
Spec Gravity:7.5 LB/GAL
Evaporation Rate & Reference:<1 (N-BUAC = 1)
Solubility in Water:MODERATELY SOLUBLE
Appearance and Odor:GRAY/BLACK LIQUID, ORGANIC SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:OPEN FLAME
Hazardous Decomposition Products:IRRITATING &/OR TOXIC FUMES INCLUDING
CARBON, OXIDES OF SULFUR & COMPLEX HYDROCARBONS MAY BE RELEASED.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF WASTE IN A CHEMICAL LANDFILL I/A/W
CURRENT FEDERAL, STATE AND LOCAL LAWS & REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF IN CONFINED AREA,USE AIR-SUPPLIED TYPE
RESPIRATOR.
Ventilation:LOCAL EXHAUST IS REQUIRED;USE MECHANICAL IF AVAILABLE.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:CHROMIUM (SARA III)
OSHA PEL:1 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:IRON ION (FE +2)
Fraction by Wt: 3.0%
OSHA PEL:1 MG/M3 (FE)
Ingred Name:SILICON (1-5%)
Fraction by Wt: 3.0%
Ingred Name:BORON (1-5%)
ACGIH TLV:0 MG/CUM
Ingred Name:NICKEL
ACGIH TLV:1 MG/CUM
* Hazards Identification *
Effects of Overexposure:W/O VENTILATION IN CONFINED AREA,POTENTIAL MAY
EXIST FOR INHALATION OF FUMES &/OR DUST FR THERML.SPR
* First Aid Measures *
First Aid:REMOVE TO WELL-VENTILATED AREA.OBTAIN MEDICAL ASSISTANCE IF
NECESSARY.
* Accidental Release Measures *
Spill Release Procedures:NORMAL HOUSEKEEPING-VACUUM CLEANING
*Handling and Storage *
Handling and Storage Precautions:REFER TO AMERICAN WELDING SOCIETY
SPRAYING
* Physical/Chemical Properties *
HCC:N1
Appearance and Odor:METALLIC POWDER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE GIVEN
Hazardous Decomposition Products:NONE GIVEN
* Disposal Considerations *
Waste Disposal Methods:NORMAL INDUSTRIAL WASTE PROCEDURE IN ACCORDANCE
WITH (IAW)FEDERAL,STATE,LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
* Product Identification *
Preparer's Name:DOD HMIS/DGSC-SSH
* Composition/Information on Ingredients *
Ingred Name:ASBESTOS, CHRYSOTILE
OSHA PEL:0.2 FIBERS/CC
Ingred Name:ASBESTOS & NATURAL/SYNTHETIC RUBBER COMPOSITION
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
*Handling and Storage *
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
* Physical/Chemical Properties *
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
* Disposal Considerations *
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE
OR AN EMERGENCY OCCURS; WEAR AN MSHA/NIOSH APPROVED AIR-SUPPLIED
Ventilation:USE LOCAL EXHAUST TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:APPROPRIATE CLOTHING & EQUIPMENT TO PREVENT
POSSIBILITY OF SKIN CONTACT. EYE WASH STATION & SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
KEY1=C1. PART OF 8 PART KIT. PRODUCT (ASBESTEST KIT) HAS BEEN
* Product Identification *
Product ID:ASBESTEST KIT SULFURIC ACID
Kit Part:Y
CAGE:ECAPP
* Composition/Information on Ingredients *
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
Ingred Name:WATER
Fraction by Wt: 2%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SULFURIC ACID IS A SEVERE EYE,
PULMONARY & SKIN IRRITANT. CAUSES BURNS ON CONTACT WITH EYES, SKIN,
MUCOUS MEMBRANES OF NOSE/THROAT/ESOPHAGUS. CHRONIC:
PROLONGED/REPEATED EXPOSURE MAY CAUSE DERMATITIS , CONJUNCTIVITIS,
EROSION OF TEETH.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:INHALED-HEADACHE, COUGH, INCREASED RESPIRATORY
RATE, PULMONARY EDEMA, TIGHTNESS IN CHEST, CYANOSIS, HYPOTENSION,
BRONCHITIS, EMPHYSEMA. EYES-SEVERE DAMAGE WITH POSSIBLE BLINDNESS,
TEARING. SKIN-PAIN, BURNS, VASICULATION. INGESTED-SEVERE BURNING
PAIN IN MOUTH/THROAT & ABDOMEN, VOMITING, DIARRHEA OR DARK BLOOD.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:IN ALL CASES GET IMMEDIATE EMERGENCY MEDICAL ATTENTION!
CLOTHES & SHOES IMMEDIATELY. WASH WITH MILD SOAP & WATER. IF
BURNED, APPLY STERIL E BANDAGE. INHALED-REMOVE TO FRESH
AIR.ADMINISTER OXYGEN OR ARTIFICIAL RESPIRATION AS NEEDED.
INGESTED-IF CONSCIOUS, GIVE LARGE AMOUNTS OF WATER. DO NOT INDUCE
VOMITING!
* Fire Fighting Measures *
Flash Point:NON-FLAMMABLE
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL. FOR LARGER FIRES USE:
WATER SPRAY, FOG OR ALCOHOL FOAM.
Fire Fighting Procedures:DO NOT GET WATER INSIDE CONTAINER! WEAR
SELF-CONTAINED BREATHING APPARATUS AND FULL FIRE FIGHTER'S
PROTECTIVE GEAR. USE WATER TO COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:NEGLIGIBLE FIRE HAZARD & EXPLOSION HAZARD
WHEN EXPOSED TO HEAT OR FLAME.
* Accidental Release Measures *
Spill Release Procedures:KEEP SPILL AWAY FROM COMBUSTIBLES. STOP LEAK
IF NO RISK. USE WATER SPRAY TO REDUCE VAPORS. ISOLATE AREA/DENY
ENTRY. DIKE AHEAD OF SPILL. VENTILATE ENCLOSED AREAS BEFORE
ENTERING.
Neutralizing Agent:SLAKED LIME, SODIUM BICARBONATE, CAUSTIC SODA.
*Handling and Storage *
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
DLA-HMIS: STORE IN A COOL, DRY PLACE AWAY FROM INCOMPATIBLE
MATERIALS, WATER.
Other Precautions:MAY IGNITE OTHER COMBUSTIBLE MATERIALS. VIOLENT
REACTION WITH WITH WATER. FLAMMABLE, POISONOUS GASES MAY ACCUMULATE
IN CONFINED SPACES. RUNOFF TO SEWER MAY CREATE FIRE OR EXPLOSION
HAZARD.
* Physical/Chemical Properties *
HCC:C1
Vapor Density:3.4
Spec Gravity:1.8
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS TO DARK BROWN, OILY LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
POWDERED METALS, HYDROFLUORIC ACID, HYDROCHLORIC ACID, PERCHLORATES,
SODIUM HYDROXIDE, SODIUM CHLORATE, SODIUM CARBONATE
Stability Condition to Avoid:VIOLENT EXOTHERMIC REACTION WITH WATER &
ORGANIC MATERIALS. MAY IGNITE FINELY DIVIDED COMBUSTIBLE MATERIALS
ON CONTACT.
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE HIGHLY TOXIC FUMES OF SULFUR OXIDES.
* Disposal Considerations *
Waste Disposal Methods:NONE SPECIFIED BY MANUFACTURER. DLA-HMIS:
DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
ENVIRONMENTAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF PERSONAL EXPOSURE CAN'T BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, WEAR A PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESPIRATOR APPROVED BY NIOSH/MSHA. WHEN
SANDING/ABRADING, WEAR A PARTI CULATE RESPIRATOR APPROVED BY
NIOSH/MSHA
Ventilation:LOCAL/GENERAL EXHAUST VENTILATION.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:DIETHYLENE GLYCOL METHYL ETHER, 2-(2-METHOXYETHOXY) ETHANOL
METHYL CARBITOL
Fraction by Wt: 4%
Ingred Name:OXO-TRIDECYL ACETATE
Fraction by Wt: 3%
Ingred Name:COLUMBIA CARBON, CARBON BLACK, LAMPBLACK, BLACK PEARLS
Fraction by Wt: 1%
Other REC Limits:3.5 MG/CUM (NIOSH)
OSHA PEL:3.5 MG/CUM
ACGIH TLV:3.5 MG/CUM
Ingred Name:WATER
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:OVEREXPOSURE-EYES, SKIN & RESPIRATORY
SYSTEM IRRITATION. MAY CAUSE NERVOUS SYSTEM DEPRESSION. LONG TERM
EXPOSURE TO HIGH LEVELS OF SILICA DUST, MAY CAUSE LUNG DAMAGE &
POSSIBLY CANCER. PROLONGED OVERE XPOSURE TO SOLVENTS MAY CAUSE
ADVERSE EFFECTS TO THE LIVER & URINARY SYSTEMS.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, NAUSEA, LOSS
OF COORDINATION, REDNESS, ITCHING/BURNING.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. KEEP WARM
& QUIET. SKIN: WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH W/WATER
* Fire Fighting Measures *
Extinguishing Media:CO2, DRY CHEMICAL, ALCOHOL FOAM.
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT W/SCBA. WATER
SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE. USE WATER TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE EXPOSED TO
EXTREME HEAT.
* Accidental Release Measures *
Spill Release Procedures:REMOVE IGNITION SOURCES. VENTILATE & REMOVE
W/INERT ABSORBENT.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
TRANSFER ONLY TO APPROVED CONTAINERS W/COMPLETE & APPROPRIATE
LABELING. DON'T TAKE INTERNALLY.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID BREATHING OF
VAPORS & SPRAY MIST. AVOID CONTACT W/SKIN & EYES.
REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE.
* Physical/Chemical Properties *
Vapor Density:>1
pH:9-9.5
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:BLACK
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:BY FIRE: CO2, CO, OXIDES OF METALS.
* Disposal Considerations *
Waste Disposal Methods:NOT HAZARDOUS. INCINERATE IN APPROVED FACILITY.
DON'T INCINERATE CLOSED CONTAINERS. DISPOSE OF IAW/FEDERAL, STATE &
LOCAL REGULATIONS.
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:AVOID CONTINUOUS BREATHING OF VAPORS AND SPRAY
MISTS. A NIOSH APPROVED SELF CONTAINED BREATHING APPARATUS REQUIRED
FOR CONCENTRATIONS ABOVE TLV LIMITS.
Ventilation:USE WITH ADEQUATE VENTILATION SUFFICIENT TO PREVENT
INHALATION OF SOLVENT VAPORS.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:PETRO HYDROCARBS POSE POTNTL HUMAN HLTH RISKS; MAY VARY
FROM PERSON TO PERSON. AS PREC, EXPOS TO LIQS, VAPS, MISTS OR FUMES
SHOULD BE MINIMIZED. ANIMAL TEST STUDY RPTS SHOW POSS EFTS T O
LIVER, KIDNEYS & LUNGS; ALSO EMBRYO/FETOTOX EFTS. RELEVANCE TO MAN
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (MINERAL SPIRITS). %
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:LIGROINE; (VARNISH MAKERS & PAINTER NAPHTHA). % WT:
Ingred Name:ETHANOL, 2-PROPOXY-; (ETHYLENE GLYCOL MONOPROPYL ETHER). %
OSHA PEL:N/K
ACGIH TLV:N/K
ACGIH TLV:ASPHYXIANT
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:EYES & RESP TRACT. POSS HDCH & DIZZ, ARE ANESTH &
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: EXPOS TO SOLV VAP CONCS
EXCEEDING ESTABLISHED THRESHOLD LIM VALUES CAN CAUSE RESP SYS
IRRIT. SYMPS OF OVEREXP ARE IRRIT, HDCH, DIZZ, NAUS, POSS UNCON &
ASPHY. EYES: MAY CAUSE EYE IRRIT E SP UPON DIRECT CNTCT W/SPRAY.
SKIN: PRLNGD/RPTD LIQ CNCT MAY CAUSE DEFAT OF SKIN LEADING TO IRRIT
& (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: DERM. INGEST: ACCIDENTAL INGEST IS
UNLIKELY FROM AEROSOL CAN. CHRONIC: TOLUENE APPEARS ON THE NAVY
LIST OF OCCUP CHEM REPRO HAZS. SEEK CONSULTATION FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG & EXPOS
INFO . ING 1:NONE CURRENTLY KNOWN. ING 2:HLTH STUDIES SHOW MANY
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHALATION: REMOVE PATIENT TO FRESH AIR. IF BREATHING STOPS,
BEGIN ARTIFICIAL RESPIRATION. SEEK MEDICAL ATTENTION. EYE:
MINUTES. GET MEDICAL ATTENTION. SKIN: WASH WITH SOAP AND WATER.
INGESTION: IF INGESTED, CALL MD IMMEDIATELY.
* Fire Fighting Measures *
Flash Point Method:TOC
Lower Limits:SEE INGS
Extinguishing Media:USE CARBON DIOXIDE, DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP. WATER
SPRAY MAY BE INEFTIVE BUT MAY BE USED TO COOL CNTNRS TO PVNT
BURSTING. IF WATER IS USED, FOG NOZZS PREF.
Unusual Fire/Explosion Hazard:EXPOSURE TO HEAT MAY CAUSE BURSTING OF
AEROSOL CAN.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION, AVOID
BREATHING VAPORS, VENTILATE AREA. WIPE UP WITH INERT MATERIAL AND
PLACE IN APPROPRIATE CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
HEAT OR PROLONGED EXPOSURE TO SUN MAY CAUSE BURSTING.
Other Precautions:USE ONLY AS DIRECTED. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING VAPORS AND INHALING CONTENTS CAN BE
HARMFUL OR FATAL. PERIODICALLY, USER SHOULD REQUEST A NEW MSDS TO
ASSURE IT MATCHES CURRENT I NFORMATION.
* Physical/Chemical Properties *
Vapor Density:HVR/AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE.
PILOT LIGHTS OR OPEN FLAMES.
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO DECOMPOSITION. FUMES MAY CONTAIN CARBON DIOXIDE AND/OR
CARBON MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DO NOT INCINERATE. DISPOSE OF IN ACCORDANCE WITH
LOCAL, STATE AND FEDERAL REGULATIONS. DO NOT PLACE CANS IN HOME
COMPACTOR. DO NOT PUNCTURE.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SHOULD BE NEEDED.
W/CONDITIONS.USE PORCESS ENCLSR/LOC EXHAU VENT/OTHER (SUPPL)
Other Protective Equipment:PROTECTIVE CLOTHING APPROPRIATE FOR RISK OF
EXPOSURE. EYEBATH, WASHING FACILITIES, SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS WELL AFT HNDLG.WASH CONTAMIN CLOTH
BEF REUSE;DESTROY/CLEAN WELL CONTAMIN SHOES.FOLLOW GOOD HYGIENE
PRACTICE
Supplemental Safety and Health
RECOMMENDED EXPO LIMITS. PNIND:A-PART A,B-PART B,C-PART C. HCC=C3.
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:ACETIC ACID,POTASSIUM SALT/POTASSIUM ACETATE
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:GLUTARALDEHYDE-BIS-POTASSIUM BISULFITE
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM SULFITE
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:EXPECTED TO BE A LOW HAZARD FOR
RECOMMENDED HANDLING. EYES:CAUSES IRRITATION. SKIN:CAUSES IRRIT.MAY
CAUSE ALLERGIC SKIN REACTION. INGEST:EXPECTED TO BE LOW INGEST
HAZ.MAY CAUSE IRRIT OF GASTROIN TESTINAL TRACT.
Explanation of Carcinogenicity:PER MSDS:CARCINOGENICITY
CLASSIFICATION:IARC/ACGIH/NTP/OSHA:NONE.
Effects of Overexposure:EYE IRRITATION. SKIN IRRITATION. ALLERGIC SKIN
REACTION. GASATROINTESTINAL TRACT IRRIT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL:MOVE TO FRESH AIR.TREAT SYPMTOMATICALLY.SYPMTOMS OCCUR
GET MED ATTN. EYES:IMMED FLUSH W/PLENTY OF WATER FOR @LEAST
W/NON-ALKALI NE(ACID)TYP SKIN CLEANER.IRRIT/ALLERGICSKIN RX
DEVELOPS GET MED ATT. INGEST:DRINK 1-2 GLASSES OF WATER.SEEK MED
ATTN.
* Fire Fighting Measures *
Flash Point:NONE,NON-COMBUST
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE. NON-COMBUSTIBLE LIQUID.
* Accidental Release Measures *
Spill Release Procedures:MAY REQUIRE NEUTRALIZATION IF
W/VERMICULITE OR OTHER INERT MATERIAL, THEN PLACE IN CONTAINER FOR
CHEMICAL WASTE. CLEAN SURFACE THOROUGHL Y TO REMOVE RESIDUAL
CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID EYE/SKIN/CLOTH CONTACT.USE
W/ADEQUATE VENTI.ROUTINE USE OF NONALKALINE(ACID)TYP HDCLNR/REG
Other Precautions:KEEP CNTNR CLSD.KEEP AWAY FRM INCOMP MATL.
* Physical/Chemical Properties *
HCC:C1
Vapor Density:0.6
pH:SUPPLE
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID, YELLOW COLOR, SLIGHT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:SULFUR DIOXIDE. HAZ COMBUST PROD:NONE
(NON0COMBUSTIBLE).
* Disposal Considerations *
Waste Disposal Methods:DISCHARGE/TREATMENT/DISPOSAL MAY BE SUBJECT TO
NATIONAL/STATE/LOCAL LAWS.MAY REQUIRE NEUTRALIZATION IF
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
Ventilation:USE ADEQ GEN/LOC EXHST VENT TO KEEP AIRBORNE CONCS BELOW
Other Protective Equipment:ANSI APPROVED EYE WASH AND DELUGE SHOWER .
WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN EXPOSURE.
Supplemental Safety and Health
OTHER PRECS:HEAT, SPKS/OPEN FLAME. EXTING MEDIA:FIRES:USE DRY CHEM,
* Product Identification *
* Composition/Information on Ingredients *
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: MAY CAUSE MODERATE EYE IRRIT.
VAPS MAY CAUSE EYE IRRIT. SKIN: MAY BE HARMFUL IF ABSORBED THRU
SKIN. MAY BE METABOLIZED TO CYANIDE WHICH IN TURN ACTS BY
INHIBITING CYTOCHROME OXIDASE IMPAIRING CEL LULAR RESPIRATION.
INGEST: MAY CAUSE IRRIT OF DIGESTIVE TRACT. MAY CAUSE EFTS SIMILAR
TO THOSE FOR INHAL EXPOS. INHAL: HARMFUL IF INHALED. INHAL OF HIGH
CONCS MAY CAUSE CNS EFTS CHARACTERIZED BY HDCH, DIZZ, UNCON &
COMA. MAY CAUSE LIVER & KIDNEY DMG. VAPS MAY CAUSE DIZZ OR
SUFFOCATION. MAY CAUSE NAUS, DIZZ & HDCH. INHAL MAY LEAD TO DIZZ,
WEAK & DROW, LEADING TO STUPOR, UNCON & EVEN DEATH. INHAL MA Y LEAD
TO(EFTS OF OVEREXP)
Effects of Overexposure:HLTH HAZ: HEMATEMESIS, CONVULSIONS, CHOCK, COMA
& POSSIBLE DEATH. CHRONIC: CHRONIC INHAL & INGEST MAY CAUSE EFTS
SIMILAR TO THOSE OF ACUTE INHAL & INGEST. MAY BE METABOLIZED TO
CYANIDE WHICH IN TURN A CTS BY INHIBITING CYTOCHROME OXIDASE
IMPAIRING CELLULAR RESPIRATION. ANIMAL STUDIES HAVE REPORTED THAT
FETAL EFTS/ABNORMALITIES MAY OCCUR WHEN MATERNAL TOXICITY IS SEEN.
* First Aid Measures *
LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. SKIN: GET MED AID
WHILE REMOV ING CONTAM CLTHG & SHOES. INGEST: IF VICTIM CONSCIOUS &
ALERT, GIVE 2-4 CUPFULS OF MILK OR WATER. NEVER GIVE ANYTHING BY
MOUTH TO UNCON PERSON. GET MED AID IMMED. INHAL: GET MED AID
IMMED. REMOVE FRO M EXPOS TO FRESH AIR IMMED. IF BRTHG IS DFCLT,
GIVE OXYG. NOTES TO MD: EXPOS SHOULD BE TREATED AS CYANIDE
POISONING. EFTS MAY BE DELAYED. ANTIDOTE: ALWAYS HAVE CYANIDE
ANTIDOTE KIT ON HAND WHEN WORING W/CYANIDE CMPDS. GET MED ADVICE
TO USE.
* Fire Fighting Measures *
Lower Limits:4.4%
Extinguishing Media:SM FIRES:USE DRY CHEM, CO*2, WATER
SPRAY/ALCOHOL-RESIST FOAM. USE WATER SPRAY TO COOL FIRE-EXPOS
CNTNRS. WATER MAY BE INEFFECTIVE. DO NOT USE STRAIGHT STREAMS OF
WATER. LG (SUPDAT)
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . NFPA RATING: HEALTH-2; FLAMMABILITY-3; REACTIVITY-0.
Unusual Fire/Explosion Hazard:CNTNRS CAN BUILD UP PRESS IF EXPOS TO
HEAT &/OR FIRE. VAPS MAY FORM EXPLO MIX W/AIR. VAPS CAN TRAVEL TO
IGNIT SOURCE & FLASH BACK. COMBUST GENERATES TOX FUMES. USE WATER
SPRAY TO KEEP FIRE-EXPOS CNTNR S COOL. FLAM LIQ. VAPS MAY BE
HVR/AIR. THEY CAN SPREAD ALONG GROUND & COLLECT IN LOW/CONFINED
AREAS. CNTNRS MAY (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTIVE EQUIPMENT.
AVOID RUNOFF INTO STORM SEWERS AND DITCHES WHICH LEAD TO WATERWAYS.
REMOVE ALL SOURCES OF IGNITION. ABSORB SPILL USING AN ABSORBENT,
NON-COMBUSTIBLE MATERIAL SUCH AS EARTH, SAND OR VERMICULITE. A
VAPOR SUPPRESSING FOAM MAY BE USED TO REDUCE VAPORS. WATER SPRAY
MAY REDUCE VAPOR BUT MAY NOT PREVENT IGNITION IN CLOSED SPACES.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPKS & FLAME.
KEEP AWAY FROM SOURCES OF IGNIT. STORE IN TIGHTLY CLOSED CNTNR.
KEEP FROM CNTCT W/OXIDIZING MATLS. STORE IN COOL, DRY, WELL-VENTD
AREA AWAY FROM INCOMPAT SUBSTANCES. WASH THOROUGHLY AFTER HNDLG.
REMOVE CONTAM CLTHG & WASH BEFORE USE. USE ONLY IN WELL VENTD AREA.
Other Precautions:GROUND & BOND CNTNRS WHEN TRANSFERRING MATL. AVOID
CNTCT W/EYES, SKIN & CLTHG. EMPTY CNTNRS RETAIN PROD RESIDUE (LIQ
&/OR VAP) & CAN BE DANGEROUS. KEEP CNTNR TIGHTLY CLSD. AVOID CNTCT
W/HEAT, SPKS & F LAME. DO NOT INGEST/INHALE. DO NOT PRESSURIZE,
CUT, WELD, BRAZE, SOLDER, DRILL, GRIND/EXPOSE EMPTY C NTNRS TO
(SUPDAT)
CO*2, ALCOHOL-RESIST FOAM/WATER SPRAY. COOL CNTNRS W/FLOODING QTYS
OF WATER UNTIL WELL AFTER FIRE IS OUT. EXPLO HAZ:MAY EXPLODE WHEN
* Physical/Chemical Properties *
Decomp Temp:Decomp Text:NOT AVAILABLE
Vapor Density:1.4(AIR=1)
pH:NOT AVAILABLE
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID; SWEETISH ODOR - AROMATIC
ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CHLORINE FLUORIDE, FLUORINE, 2-CYANO-2-PROPYL NITRATE, DINITROGEN
TETRAOXIDE, INDIUM, DIPHENYL SULFOXIDE, TRICHLOROSILANE, N-FLUORO
CMPDS, IRON (III) PERCHLORATE, LANTHANIDE, NITRIC ACID, PERCHLORIC
ACID, SULFURIC ACID, SUL
Stability Condition to Avoid:STABLE UNDER NORMAL TEMPERATURES AND
PRESSURES. AVOID INCOMPATIBLE MATERIALS, IGNITION SOURCES.
Hazardous Decomposition Products:HYDROGEN CYANIDE, NITROGEN OXIDES,
CARBON MONOXIDE, CARBON DIOXIDE.
* Toxicological Information*
CLASSIFIABLE AS HUMAN CARCIN. EPIDEMIOLOGY - NO INFO AVAIL.
TETRAGENICITY - EMBRYO OR FETUS: STUNTED FETUS, IHL -HAMSTER
* Ecological Information *
ENVIRONMENTAL FATE: NO INFO REPORTED. PHYSICAL/CHEMICAL: NO INFO
AVAIL. OTHER: NONE. OTHER INFO: ADVICE IMMED (SHOW LABEL WHERE
CLASSIFICATION OF B2, D1B, D2B. IT IS NOT LISTED ON CANADA'S INGRED
(TRANSPORT INFO)
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE AND LOCAL REGULATIONS. RCRA D-SERIES MAXIMUM CONCENTRATION OF
CONTAMINANTS: NONE LISTED. RCRA D-SERIES CHRONIC TOXICITY REFERENCE
LEVELS: NONE LIS TED. RCRA F-SERIES: NONE LISTED. RCRA P-SERIES:
WASTE; TOXIC WASTE).
* MSDS Transport Information *
Transport Information:SHIPPING NAME - US DOT: ACETONITRILE; IATA: NO
INFO AVAIL; RID/ADR: NO INFO AVAIL. IMO: NO INFO AVAIL.
ACETONITRILE. HAZ CLASS - US DOT: 3; IMO: 3(6.1). UN NUMBER: US
ADDNL INFO: IMO: FLASHPOINT 6C. ECOLOGICAL INFO: SKIN
* Regulatory Information *
PRODUCT HAVE TPQ. SARA CODES: ACUTE, CHRONIC, FLAMMABLE. SECTION
HAVE SNUR UNDER TSCA. CLEAN AIR ACT: LISTED AS HAZ AIR POLLUTANT
(HAP). MATL DOES NOT CNTN ANY CLASS 1 OR CLASS 2 OZONE DEPLETORS.
CLEAN WATER ACT: NONE OF CHEMS IN PROD LISTED AS HAZ SUBSTANCES
UNDER C WA. NONE OF CHEMS LISTED AS PRIORITY OR TOX POLLUTANTS
UNDER CWA. NONE CONSIDERED HIGHLY HAZ BY OSHA.
EUROPEAN/INTERNATIONAL (OTHER INFO)
STATE RIGHT TO KNOW LISTS: CALIFORNIA, NEW JERSEY, FLORIDA,
PENNSYLVANIA, MINNESOTA, MASSACHUSETTS. CALIFORNIA NO SIGNIFICANT
RISK LEVEL: NONE OF CHEMS IN THIS P ROD ARE LISTED. TRANSPORT INFO:
KOREA CHECK ACGIH. TLV OEL IN NEW ZEALA ND, SINGAPORE, VIETNAM
CHECK ACGIH TLV.
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
BY DGSC-STF.
* Product Identification *
* Composition/Information on Ingredients *
* Hazards Identification *
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
* First Aid Measures *
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
* Fire Fighting Measures *
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
* Accidental Release Measures *
*Handling and Storage *
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
* Physical/Chemical Properties *
HCC:A3
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-IN ACCORDANCE WITH
DOD REGULATIONS AND FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NORMALLY REQUIRED.IF EXPOSURES ARE NOT
"WARNINGS".COMBINATION FILTER/ORGANIC VAPO R CARTRIDGES OR CANISTER
MAY BE USED.
Ventilation:PROVIDE SUFFICIENT GENERAL/LOCAL EXHAUST VENTILATION IN
PATTERN/VOLUME TO CONTROL INHALATION EXPOSURE < EXPOSURE LIMITS.
Other Protective Equipment:IMPERVIOUS PROTECTIVE GARMENTS SUCH AS
HEAD/NECK COVER,APRONS,JACKETS,PANTS,BOOTS,ETC.EYE-WASH
FACILITIES,SAFETY SHOWER.
Work Hygienic Practices:AVOID CONTACT WITH EYES AND SKIN;DO NOT BREATHE
VAPORS/MIST.WASH THOROUGHLY AFTER EACH USE.
Supplemental Safety and Health
DO NOT USE UNTIL MANUFACTURER'S PRECAUTIONS HAVE BEEN READ &
UNDERSTOOD. WASH EXPOSED AREAS PROMPTLY AND THOROUGHLY AFTER SKIN
CONTACT FROM WORKING WITH THIS PRODUCT AND BEFORE EATING,DRINKING
OR USIN G REST ROOMS.DO NOT WEAR CONTACT LENS WITHOUT PROPER EYE
PROTECTION WHEN USING THIS PRODUCT.
* Product Identification *
Product ID:COAL TAR CREOSOTE-PRESS/NON-PRESS/GEN.APPLI
* Composition/Information on Ingredients *
Ingred Name:CREOSOTE (SARA III)
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:INDENE
Other REC Limits:NONE SPECIFIED
Ingred Name:NAPHTHALENE (SARA III)
Other REC Limits:NONE SPECIFIED
Ingred Name:DIPHENYL (BIPHENYL) (SARA III)
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.2 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:BENZENE (SARA III)
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
Ingred Name:ALKYL NAPHTHALENE
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE-EYE:MAY CAUSE MODERATE
IRRITATION.SKIN:CAN RESULT IN SEVERE IRRITATION WHICH WHEN
ACCENTUATED BY SUNLIGHT MAY RESULT IN PHOTOTOXIC SKIN
REACTION.INHALATION:IRRITATION,CNS EFFECTS,SUCH AS HEADACH
E,DIZZINESS,COMA AND POSSIBLE
DEATH.INGESTION:IRRITATION,NAUSEA,VOMITING & ABDOMINAL
PAIN.CHRONIC-MAY CAUSE CANCER.
Explanation of Carcinogenicity:BENZENE. IARC LISTS CREOSOTE AS A
POSSIBLE CARCINOGENIC AGENT TO HUMAN.
Effects of Overexposure:WARNING! MAY CAUSE CANCER. MAY BE FATAL IF
SWALLOWED. HARMFUL TO THE SKIN OR IF INHALED. CAUSES EYE AND SKIN
IRRITATION.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING DISEASE
IN OR A HISTORY OF AILMENTS INVOLVING THE SKIN OR BLOOD-FORMING
ORGANS MAY BE AT A GREATER RISK OF DEVELOPING ADVERSE HEALTH
EFFECTS WHEN EXPOSED TO THIS MATERIAL.
* First Aid Measures *
MINUTES.SKIN:WIPE MATERIAL OFF.WASH THOROUGHLY WITH SOAP &
WATER/WATERLESS HAND CLEANER.INHALATION:REMOVE TO FRESH AIR.GIVE
CPR/OXYGEN IF NEEDED.INGESTION: GIVE 1-2 GLASSES OF WATER/MILK IF
CONSCIOUS.INDUCE VOMITING USING IPECAC SYRUP.THEN,GIVE A SLURRY OF
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL. WATER OR FOAM MAY CAUSE FROTHING, IF MOLTEN.
Fire Fighting Procedures:WEAR COMPLETE FIRE SERVICE PROTECTIVE
EQUIPMENT,INCLUDING FULL-FACE MSHA/NIOSH APPROVED SELF-CONTAINED
BREATHING APPARATUS.USE WATER TO COOL CONTAINERS BY FIRE.
Unusual Fire/Explosion Hazard:TOXIC VAPORS/DECOMPOSITION PRODUCTS MAY
BE RELEASED FORMING FLAMMABLE/EXPLOSIVE MIXTURES IN AIR. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
* Accidental Release Measures *
Spill Release Procedures:STOP LEAK IF NO RISK INVOLVED.STAY
UPWIND.SOLIDIFIED SPILL:SHOVEL INTO DRY CONTAINERS AND COVER.FLUSH
AREA WITH WATER.SMALL WET SPILL:TAKE UP WITH SAND.FLUSH AREA WITH
WATER.DIKE LARGE SPILLS FOR LATE R DISPOSAL.CONTAIN RUNOFF FROM
FIRE CONTROL.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL,DRY AND WELL VENTILATED
AREA.KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:AVOID PROLONGED/REPEATED BREATHING OF
VAPORS,MISTS/FUMES.AVOID PROLONGED/REPEATED CONTACT WITH
SKIN/EYES.APPLICATION OF CERTAIN PROTECTIVE CREAMS (SUN SCREENS FOR
COAL TAR PRODUCTS) BEFORE WORKING/SEV ERAL TIMES DURING WORK MAY BE
BENEFICIAL
* Physical/Chemical Properties *
HCC:V1
Vapor Density:>1
Evaporation Rate & Reference:SLOW (N-BUTYL ACETATE=1)
Solubility in Water:SLIGHT
Appearance and Odor:BROWN TO BLACK LIQUID WITH CREOSOTE OR TARRY ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:HIGH TEMPERATURES AND OPEN FLAMES
Hazardous Decomposition Products:OXIDES OF CARBON
* Disposal Considerations *
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES;DISPOSAL MUST BE IN
ACCORDANCE WITH LOCAL,STATE AND FEDERAL REGULATIONS. THIS PRODUCT
RELEASED INTO THE ENVIRONMENT MUST BE REPORTED TO THE NATIONAL
1 LB.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE RESPIRATOR OR FACE MASK WHEN SPRAYING CANS
UNDER WINDY CONDITION.
Ventilation:PRODUCT APPLIED OUTDOORS.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER USING.
Supplemental Safety and Health
* Product Identification *
Product ID:GREEN TREE MARKING PAINT
* Composition/Information on Ingredients *
Ingred Name:MINERAL SPIRITS (PETROLEUM SPIRITS) TYPE-LOW AROMATIC
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Health Hazards Acute and Chronic:UNDER NORMAL HANDLING IN OUTDOOR USE,
PRODUCT IS NOT HAZARDOUS. PAINT IS HARMFUL IF INHALED IN UNUSUAL
AMOUNTS OR INGESTED. SOLVENT IS IRRITANT FOR EYES AND CAN BE
IRRITATING TO SKIN.
Medical Cond Aggravated by Exposure:RESPIRATORY AILMENTS OR ALLERGIES.
SENSITIVE SKIN; SKIN ALLERGIES.
* First Aid Measures *
First Aid:INHALE: REMOVE PERSON TO FRESH AIR. CALL PHYSICIAN. INGEST:
EYEWASH, EYEDROPS. SKIN: REMOVE PAINT WITH SOAP AND WATER AS SOON
AS POSS IBLE. APPLY SKIN LOTION OR MINERAL OIL IF DESIRED.
* Fire Fighting Measures *
Extinguishing Media:FOAM, "ALCOHOL" CO2 FOAM, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:USE AIR SUPPLIED BREATHING APPARATUS WHEN
FIGHTING FIRE IN ENCLOSED AREAS.
Unusual Fire/Explosion Hazard:PRESSURIZED CANS CAN EXPLODE WHEN HEATED.
IF POSSIBLE, KEEP CANS COOL WITH WATER.
* Accidental Release Measures *
Spill Release Procedures:COLLECT IN ABSORBENT MATERIAL. REMOVE ALL
SOURCES OF IGNITION.
*Handling and Storage *
SOURCES. KEEP CONTAINER CLOSED WHEN NOT IN USE. KEEP FROM HEAT,
SPARKS AND OPEN FLAME.
Other Precautions:DO NOT INHALE MIST OR VAPOR. APPLY WITH BACK TO WIND.
DO NOT TAKE INTERNALLY. WASH OR CLEAN CONTAMINATED CLOTHES BEFORE
REUSE. DO NOT INCINERATE EMPTY OR PARTIALLY FILLED CONTAINERS.
AVOID CONTACT WIT H EYES AND SKIN.
* Physical/Chemical Properties *
HCC:F4
Vapor Density:> THAN AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORSEEABLE.
Stability Condition to Avoid:EXTREMES IN TEMPERATURES. HEAT, SPARKS,
OPEN FLAME, ELECTRICAL EQUIPMENT, WELDING EQUIPMENT.
Hazardous Decomposition Products:BURNING CAN PRODUCE CARBON MONOXIDE.
Conditions to Avoid Polymerization:EXTREMES IN TEMPERATURES. HEAT,
SPARKS, OPEN FLAME, ELECTRICAL EQUIPMENT, WELDING EQUIPMENT.
* Disposal Considerations *
Waste Disposal Methods:MUST FOLLOW FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF ENGINEERING CONTROLS DO NOT MAINTAIN AIRBORNE
CONCENTRATIONS BELOW RECOMMENDED EXPOSURE LIMITS, AN APPROVED
RESPIRATOR MUST BE WORN. RESPIRATOR TYPE: ORGANIC VAPOR, ACID GAS.
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER, WASHING
FACILITIES. WEAR PROTECTIVE CLOTHING APPROPIATE FOR THE RISK OF
EXPOSURE.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
KEY 2: N1, THIS ITEM IS PART OF A KIT. DANGER! CONTAINS:
GLUTERALDEHYDE. HARMFUL IF SWALLOWED. KEEP OUT OF REACH OF
CHILDREN.
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:WATER
Other REC Limits:NONE RECOMMENDED
Ingred Name:GLUTARALDEHYDE-BIS-SODIUM BISULFITE,
Other REC Limits:NONE RECOMMENDED
Ingred Name:GLUTARALDEHYDE
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 0.2 PPM
Ingred Name:ACETIC ACID (CERCLA)
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: VAPOR IRRITATING. EYES:
CAUSES SEVERE BURNS. VAPOR IRRITATING. SKIN: CAUSES SEVERE BURNS.
MAY CAUSE ALLERGIC SKIN REACTION. INGESTION: HARMFUL IF SWALLOWED.
MAY CAUSE BURNS OF THE GASTROIN TESTINAL TRACT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:ALTHOUGH IT IS NOT KNOWN THAT
GLUTARALDEHYDE IS A RESPIRATORY TRACT IRRITANT & MAY AGGRAVATE
PRE-EXISTING ASTHMATIC DISORDERS, THE SUPPORTING DATA FOR
RESPIRATORY SENSITIZATION ARE LESS CONCLUSIVE.
* First Aid Measures *
First Aid:INHALATION: MOVE TO FRESH AIR. TREAT SYMPTOMATICALLY. GET
MEDICAL ATTENTION. EYES: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR
SOILED CLOTHES. GET MEDICAL ATTENTION. INGESTION: DO NOT INDUCE
VOMITING. GIVE VICTIM A GLASS OF WATER. CALL PHYSICIAN OR POISON
CONTROL CENTER.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL
FOAM. USE WATER SPRAY TO KEEP FIRE EXPOSED CONTAINER COOL.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:MAY CAUSE SPONTANEOUS HEATING AND
IGNITION WHEN ABSORBED ON COMBUSTIBLE, POROUS MATERIALS (E.G. RAGS,
PAPER, SAWDUST, COTTON, CLOTHING).
* Accidental Release Measures *
Spill Release Procedures:FLUSH SPILLS TO SEWER WITH LARGE AMOUNTS OF
WATER. OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT
MATERIAL, THEN PLACE IN A NON COMBUSTIBLE CONTAINER FOR PROMPT
DISPOSAL. CLEAN SURFACE THOROU GHLY TO REMOVE RESIDUAL
CONTAMINATION.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED.
Other Precautions:DO NOT GET IN EYES, ON SKIN, ON CLOTHING. AVOID
BREATHING VAPOR. USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY
AFTER HANDLING.
* Physical/Chemical Properties *
HCC:C3
Vapor Density:0.6
pH:3.0
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID, CLEAR-BROWN, ALDEHYDE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:SULFUR DIOXIDE. CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF SULFUR.
Conditions to Avoid Polymerization:HAZARDOUS POLYMERIZATION MAY OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE, OR LOCAL LAWS. FLUSH TO SEWER WITH LARGE AMOUNTS
OF WATER. SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUE, FOLLOW
LABEL WARNINGS EV EN AFTER CONTAINER IS EMPTIED.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:RESPIRATORY PROTECTION REQUIRED IF AIRBORNE
CONCENTRATION EXCEEDS TLV. AT CONCENTRATIONS UP TO 9 PPM. A
HIGH-EFFICIENCY PARTICULATE RESPIRATOR IS RECOMMENDED, ABOVE THIS
LEVEL, A SELF-CONTAINED BREATH ING APPARATUS IS ADVISED.
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO MEET TLV
REQUIREMENTS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . UNIFORM.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Product ID:CUPRIC CHLORIDE, DIHYDRATE
* Composition/Information on Ingredients *
Ingred Name:COPPER (2+) CHLORIDE DIHYDRATE; (CUPRIC CHLORIDE,
DIHYDRATE)
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: IRRITATION OF NOSE
AND THROAT, HEADACHE, COUGHING, DIZZINESS, DIFFICULT BREATHING.
SKIN AND EYE CONTACT AND SKIN ABSORPTION: NONE IDENTIFIED.
INGESTION: NAUSEA, VOMITING. CHRONIC: N ONE IDENTIFIED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE IDENTIFIED.
* First Aid Measures *
First Aid:INGEST: CALL A PHYSICIAN. IF SWALLOWED, IF CONSCIOUS,
IMMEDIATELY INDUCE VOMITING. INHALATION: IF INHALED, REMOVE TO
FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT , GIVE OXYGEN. SKIN: IN CASE OF CONTACT,
FLUSH SKIN WITH WATER. EYE: IN CASE OF CONTACT, IMMEDIATELY FLUSH
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:TOXIC GASES PRODUCED: HYDROGEN CHLORIDE.
* Accidental Release Measures *
Spill Release Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE CLOTHING. WITH CLEAN SHOVEL, CAREFULLY PLACE
MATERIAL INTO CLEAN, DRY CONTAINER AND COVER; REMOVE FROM AREA.
FLUSH SPILL AREA WITH WATER.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED.
SUITABLE FOR ANY GENERAL CHEMICAL STORAGE AREA.
Other Precautions:
* Physical/Chemical Properties *
Appearance and Odor:BLUE-GREEN CRYSTALS OR POWDER.
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
POTASSIUM, SODIUM, WATER.
Stability Condition to Avoid:MOISTURE.
Hazardous Decomposition Products:HYDROGEN CHLORIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE, AND LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:REQUIRED IF TLVS ARE EXCEEDED.
Ventilation:LOCAL EXHAUST VENTILATION.
Supplemental Safety and Health
* Product Identification *
Product ID:IPS EMPRESS SPECIAL INVESTMENT LIQUID
Preparer's Name:LLOYD ZIEMENDORF
* Composition/Information on Ingredients *
ACGIH TLV:0.2 MG/CUM
Ingred Name:COLLOIDAL SILICA
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DRYNESS OF SKIN. IRRITATION OF EYES.
IRRITATION TO MUCOUS MEMBRANES. INHALATION: MAY CAUSE LUNG DAMAGE,
SILICOSIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:DRYNESS, IRRITATION.
Medical Cond Aggravated by Exposure:IMPAIRED RESPIRATORY FUNCTION.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:NONE
* Accidental Release Measures *
Spill Release Procedures:NEUTRALIZE & COLLECT ON INERT ABSORBENT. STORE
IN CLOSED CONTAINER FOR PROPER DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, DARK AREA. KEEP ALL
CONTAINERS CLOSED. DON'T ALLOW EXCESSIVE AMOUNTS OF LIQUID TO DRY.
Other Precautions:FOR PROFESSIONAL DENTAL USE ONLY.
* Physical/Chemical Properties *
Spec Gravity:>1
Appearance and Odor:ODORLESS LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . USE APPROPRIATE OSHA/MSMA APPROVED SAFETY
EQUIPMENT.
Ventilation:THIS CHEMICAL SHOULD BE HANDLED ONLY IN A HOOD.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:DELAYED LUNG INJURY. CAN CAUSE SEV HDCH. VAPS CAN CAUSE
SEV EYE INFLAM & SWELLING OF ADJOINING TISS. CAN CAUSE SENSIT BY
SKIN CONT. SUSPECTED CARCINOGEN-MAY PRDCE CANCER. POSS MUTAGEN- MAY
CAUSE BIRTH DEFECTS IN FUTURE GENERATIONS. FIRST AID PROC:PATIENT
IS HAVING DFCLTY BRTHG. IF PATIENT HAS (ING 2)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:2-FURALALDEHYDE; (2-FURANCARBOXALDEHYDE) (CERCLA)
OSHA PEL:S, 5 PPM
ACGIH TLV:S, 2 PPM
Ingred Name:SUPDAT:STOPPED BRTHG ADMIN ARTF RESPS. IF PATIENT IS IN
CARDIAC ARREST ADMIN CPR. CONTINUE LIFE SUPPORTING (ING 3)
Ingred Name:ING 2:MEASURES UNTIL MED ASSISTANCE HAS ARRIVED. INGEST:IF
PATIENT IS EXHIBITING SIGNS OF SHOCK-KEEP WARM & (ING 4)
Ingred Name:ING 3:QUIET. CONT POIS CTL CTR IMMED IF NEC. DO NOT ADMIN
LIQS/INDUCE VOMIT TO AN UNCON/CONVULSING PERSON. IF (ING 5)
Ingred Name:ING 4:PATIENT IS VOMIT-WATCH CLOSELY TO MAKE SURE AIRWAY
DOES NOT BECOME OBSTRUCTED BY VOMIT. GET MED ATTN IF NEC.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONT LENSES SHOULD NOT BE WORN IN LAB.
ALL CHEMS SHOULD BE CONSIDERED HAZ-AVOID DIRECT PHYSICAL CONT! CAN
BE HARMFUL IF INHALED, SWALLOWED, ABSORBED THRU SKIN. CAN CAUSE EYE
& SKIN IRRIT. DUST &/OR VA PS CAN CAUSE IRRIT TO RESP TRACT. CAN BE
IRRIT TO MUCOUS MEMBS. CAN CAUSE ALLERGIC SKIN & RESP RXN. (EFTS OF
OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:PRLNGD EXPOS MAY CAUSE NAUS/HDCH/DIZZ
&/OR EYE DMG. CAN BE FATAL IF ABSORBED THRU SKIN, INHALED OR
SWALLOWED! BASED ON TOX OF CMPDS OF SIMILAR STRUCTURE THIS MATL IS
PROBABLY HIGHLY HAZ. CAN CAUSE NERV SYS INJURY. CAN BE IRRIT TOMUC
MEMBS. LACHRYMATOR-CAUSES SEV EYE IRRIT. CAN CAUSE (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:AN ANTIDOTE IS SUBSTANCE INTENDED TO COUNTERACT EFT OF POIS.
IT SHOULD BE ADMIN ONLY BY MD/TRAINED EMER PERS. MED ADVICE CAN BE
OBTAINED FROM POIS CTL CTR. EYES:FLUSH CONTINUOUSLY W/WATER FOR @
OCCURRED, USE SOAP & WATER TO CLEANSE SKIN. REMOVE & WASH CONTAM
CLTHG. GET MED ATTN IF NEC. INHAL:REMOVE TO FRESH AIR. ADMIN OXYG
IF (SUPDAT)
* Fire Fighting Measures *
Lower Limits:2.1%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER OR WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE AREA. WEAR APPROPRIATE OSHA-REGULATED
VENTILATE AREA. ABSORB ON VERMICULITE OR SIMILAR
MATERIAL. SWEEP UP AND PLACE IN AN APPROPRIATE CONTAINER. HOLD FOR
DISPOSAL. WASH CONTAMINATE D SURFACES TO REMOVE ANY RESIDUE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID CONTACT WITH SKIN, EYES AND
CLOTHING. KEEP TIGHTLY CLOSED AND STORE IN A COOL, DRY PLACE. STORE
ONLY WITH COMPATIBLE CHEMICALS.
Other Precautions:PERSONS NOT SPECIFICALLY & PROPERLY TRAINED SHOULD
NOT HNDL CHEM/ITS CNTNR. PROD IS FURNISHED FOR LAB USE ONLY! PRODS
MAY NOT BE USED AS DRUGS, COSMETICS, AGRICULTURAL/PESTICIDAL PRODS,
FOOD ADDITIVES /AS HOUSEHOLD CHEMS.
* Physical/Chemical Properties *
Solubility in Water:SLIGHTLY SOLUBLE
Appearance and Odor:FRUITY, PERFUME LIKE, OR PLEASANT ODOR. NEARLY
COLORLESS TO YELLOW LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE WITH STRONG OXIDIZING AGENTS, STRONG BASES, STRONG ACIDS.
Stability Condition to Avoid:COMBUSTIBLE. SENSITIVE TO LIGHT-DARK COLOR
DOES NOT AFFECT PURITY.
Hazardous Decomposition Products:DECOMPOSITION LIBERATES TOXIC FUMES.
DECOMPOSES UPON STANDING FOR A LONG PERIOD OF TIME.
Conditions to Avoid Polymerization:AIR SENSITIVE. SENSITIVE TO HEAT.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:NOT NECESSARY
Supplemental Safety and Health
MSDS UNDATED.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:CUMENE HYDROPEROXIDE
Fraction by Wt: <3%
* Hazards Identification *
Effects of Overexposure:PROLONGED EXPOSURE TO SKIN MAY CAUSE IRRITATION
TO A SENSITIVE PERSON.
* First Aid Measures *
First Aid:SKIN & EYE: FLUSH WITH WATER. INGESTION: DO NOT INDUCE
VOMITING. SEEK MEDICAL ATTENTION.
* Fire Fighting Measures *
Extinguishing Media:FOAM, DRY CHEMICAL
Fire Fighting Procedures:SCBA/PROTECTIVE CLOTHING SHOULD BE WORN IN
FIGHTING FIRES.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:SOAK UP IN INERT ABSORBENT, STORE IN CLOSED
CONTAINER.
*Handling and Storage *
CONTACT.
* Physical/Chemical Properties *
HCC:N1
Vapor Pres:<5
Vapor Density:>AIR
Solubility in Water:LOW
Appearance and Odor:BLUE LIQUID - ODOR MILD.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:INCINERATE OR BURY IN ACCORDANCE WITH LOCAL AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NORMALLY REQUIRED. IF ENGINEERING CONTROLS
FAIL OR NON-ROUTINE USE OR AN EMERGENCY OCCURS; WEAR AN MSHA/NIOSH
APPROVED RESPIRATOR WITH DUST CARTRIDGE OR AN AIR-SUPPLIED
Ventilation:USE ADEQUATE MECHANICAL VENTILATION OR LOCAL EXHAUST TO
MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:LAB COAT, EYE WASH STATION & SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:CATALASE (FROM BOVINE LIVER)
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CONTACT MAY CAUSE SKIN AND EYE
IRRITATION. PROLONGED OR REPEATED EXPOSURE MAY CAUSE ALLERGIC
REACTION IN SOME INDIVIDUALS. INGESTION MAY CAUSE GI TRACT
DISCOMFORT. INHALATION MAY IRRITATE RESPI RATORY TRACT. CHRONIC:
MUTATION DATA CITED.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:SKIN-IRRITATION, ALLERGIC REACTION. EYES-
IRRITATION. INHALED-RESPIRATORY IRRITATION. INGESTED-GI TRACT
DISCOMFORT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
CONTAMINATED CLOTHES. WASH WITH MILD SOAP & WATER. INHALED-REMOVE
TO FRESH AIR. ADMINISTER OXYGEN OR ARTIFICIAL RESPIRATION AS
NEEDED. INGE STED-IF CONSCIOUS, GIVE LOTS OF WATER. CONTACT POISON
CONTROL CENTER AND OBTAIN IMMEDIATE MEDICAL ATTENTION.
* Fire Fighting Measures *
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:NONE EXPECTED.
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA OF SPILL. CLEAN-UP PERONNEL
SHOULD WEAR PROPER PROTECTIVE EQUIPMENT. AVOID CREATING DUST. SWEEP
OR SCOOP UP AND CONTAINERIZE FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE AWAY FROM
HEAT. DO NOT GET IN EYE, ON SKIN OR CLOTHING.
Other Precautions:WASH THOROUGHLY AFTER HANDLING. DO NOT TAKE
INTERNALLY.
* Physical/Chemical Properties *
HCC:T6
Appearance and Odor:SOLID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NO DATA AVAILABLE.
Stability Condition to Avoid:NO DATA AVAILABLE.
Hazardous Decomposition Products:UNKNOWN.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL ENVIRONMENTAL REGULATIONS. ALWAYS CONTACT A PERMITTED WASTE
DISPOSER (TSD) TO ASSURE COMPLIANCE.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING, AND BEFORE
EATING, DRINKING OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
MSDS PREPARED BY DGSC-SSH FROM ANOTHER ENTRY SAME ITEM DIFFERENT SUPPLY
SIZE.
* Product Identification *
Preparer's Name:DGSC-SSH
* Composition/Information on Ingredients *
Ingred Name:"NOT HAZARDOUS" PER MANUFACTURER
Other REC Limits:5 MG/M3 AS OIL MIST
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-SKIN:PROLONGED AND REPEATED
CONTACT CAN CAUSE IRRITATION.CHRONIC-NOT GIVEN.
Explanation of Carcinogenicity:PRODUCT CONTAINS NO INGREDIENTS
CURRENTLY CLASSIFIED AS CARCINOGENIC BY NTP, IARC OR OSHA PER
MANUFACTURER.
Effects of Overexposure:SKIN IRRITATION AND REDNESS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR.EYE: IMMEDIATELY FLUSH WITH
WATER.INGESTION:CALL PHYSICIAN.
* Fire Fighting Measures *
Flash Point Method:COC
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, SAND OR EARTH
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:ABSORB ON POROUS MATERIAL AND TRANSFER TO A
CLEAN CONTAINER.
Neutralizing Agent:NONE GIVEN.
*Handling and Storage *
Handling and Storage Precautions:AVOID FREEZING. KEEP CONTAINER CLOSED
WHEN NOT IN USE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:V6
Appearance and Odor:BROWN FLUID - MILD ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR A POSITIVE PRESSURE SUPPLIED AIR
HISTORY OF LUNG/BREATHING PROBLEMS/REACTION TO ISOCYANATES
SHOULDN'T USE/BE EXPOSED TO PRODUCT.
Ventilation:SUFFICIENT IN VOLUME & PATTERN TO KEEP CONTAMINANTS BELOW
APPLICABLE OSHA LIMITS.
Other Protective Equipment:COVERALLS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE
EATING/SMOKING.
Supplemental Safety and Health
CONTAINER & DISPOSE OF MATERIAL.
* Product Identification *
Preparer's Name:T R LOUER
* Composition/Information on Ingredients *
Fraction by Wt: 8%
Ingred Name:LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA, LACOLENE
Fraction by Wt: 2%
Ingred Name:VOLATILE ORGANIC CONTENT: 6.5 LBS/GAL
Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE
Ingred Name:HEPTANE
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
MINERAL SPIRITS
Ingred Name:BUTANOL, N-BUTYL ALCOHOL, PROPYL CARBINOL, BUTYL ALCOHOL
Fraction by Wt: 5%
Ingred Name:N-BUTYL PROPIONATE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE NOSE & THROAT
IRRITATION. EXPOSURE TO ISOCYANATES MAY CAUSE RESPIRATORY
SENSITIZATION & MAY CAUSE A DECREASE IN LUNG FUNCTION WHICH MAY BE
PERMANENT. EYES: IRRITATION/BURNING. SK IN: IRRITATION &
DERMATITIS. REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE
PERMANENT BRAIN & CNS DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:GI DISTRESS, IRRITATION, EYE WATERING,
HEADACHES, NAUSEA, DIZZINESS, LOSS OF COORDINATION, BURNING,
DISCOMFORT.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH W/PLENTY OF
ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:CC
Lower Limits:0.2
Extinguishing Media:WATER SPRAY, FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIPMENT & SCBA. WATER
FROM FOG NOZZLES MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:WHEN HEATED ABOVE THE FLASHPOINT, EMITS
FLAMMABLE VAPORS, WHEN MIXED W/AIR CAN BURN/BE EXPLOSIVE. FINE
MISTS/SPRAYS MAY BE FLAMMABLE AT TEMPS < THE FLASHPOINT.
* Accidental Release Measures *
Spill Release Procedures:DON'T BREATHE VAPORS. DON'T GET IN EYES/ON
SKIN. WEAR A POSITIVE PRESSURE SUPPLIED AIR VAPOR/PARTICULATE
OF IGNITION. ABSORB W/INERT MATERIAL. VENTILATE AREA. (SEE SUPP)
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & FLAME.
CLOSE CONTAINER AFTER EACH USE. GROUND CONTAINERS WHEN POURING.
Other Precautions:DON'T SAND, FLAME CUT, BRAZE/WELD DRY COATING W/O A
NIOSH/MSHA APPROVED RESPIRATOR/APPROPRIATE VENTILATION. DON'T
BREATHE VAPORS. DON'T PERMIT ANYONE W/O PROTECTION IN THE PAINTING
AREA.
* Physical/Chemical Properties *
Vapor Density:>1
Evaporation Rate & Reference:LESS THAN ETHER
Solubility in Water:MISCIBLE
Percent Volatiles by Volume:(SUPP)
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORSEEABLE.
Hazardous Decomposition Products:CO, CO2, SMOKE.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE/DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T ALLOW MATERIAL TO CONTAMINATE GROUND WATER
SYSTEMS. DON'T INCINERATE IN CLOSED CONTAINERS. FLAMMABLE LIQUID
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:REQUIRED IF TLV IS EXCEEDED.
Ventilation:ADEQUATE GENERAL/LOCAL
Supplemental Safety and Health
YEARS AGO. PER JACKIE SACCO
* Product Identification *
Product ID:IPS EMPRESS WAX
Preparer's Name:LLOYD ZIEMENDORF
CAGE:0T2N6
CAGE:0T2N6
* Composition/Information on Ingredients *
Ingred Name:PARAFFIN WAX FUME, PARAFFIN
ACGIH TLV:2 MG/CUM
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:BURNS FROM HOT WAX.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:BURNS FROM HOT WAX.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE CPR.
MINUTES. SKIN: IMMERSE IN COLD WATER, REMOVE HARDENED WAX
CAREFULLY. OBT AIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:DON'T USE WATER ON BURNING WAX.
* Accidental Release Measures *
Spill Release Procedures:COLLECT FOR NORMAL DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL DRY AREA.
Other Precautions:AVOID DIRECT CONTACT W/HOT WAXES.
* Physical/Chemical Properties *
Spec Gravity:-0.8-0.9
Appearance and Odor:COLORED WAXES, NO ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS
Hazardous Decomposition Products:ACID SMOKE FROM COMBUSTION.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED HEPA RESPIRATOR IF
REQUIRED. WEAR SELF-CONTAINED BREATHING APPARATUS IF REQUIRED FOR
HIGH LEVELS OF CONTAMINATES.
Ventilation:LOCAL EXHAUST SUFFICIENT TO ENTRAIN ALL PARTICULATE
EMISSIONS. HEPA FILTER REQUIRED. NO LEAKS ON PRESSURE SIDE OF FAN.
Other Protective Equipment:USE COVERALLS OR DISPOSABLE CLOTHING.
Work Hygienic Practices:WORK WET TO THE DEGREE POSSIBLE. WASH HANDS
AFTER HANDLING GASKET. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
ARRANGEMENTS SHOULD BE MADE TO REPLACE THIS BRAKE SHOE WITH A
SUBSTITUTE THAT DOES NOT CONTAIN ASBESTOS.
* Product Identification *
Product ID:WOVEN BRAKE LINING
* Composition/Information on Ingredients *
Ingred Name:ASBESTOS, CHRYSOTILE
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.2 FIBERS/CC
Ingred Name:CELLULOSE (PAPER FIBER) MANUFACTURER STATES A MIXTURE
"CELLCLOSICS"
Other REC Limits:NONE SPECIFIED
Ingred Name:PHENOLIC RESIN
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE HAZARDS ARE NOT EXPECTED WITH
THIS MATERIAL, EXCEPT FOR SKIN IRRITATION DUE TO TRAUMA. CHRONIC
HAZARDS IN ORDER OF INCREASING SEVERITY ARE: ASBESTOSIS, LUNG
CANCER, & MESOTHELIOMA, ALL OF WHICH ARE DISABLING AND FATAL
DISEASES OF THELUNG. INHALATION AND INGESTION OF ASBESTOS FIBERS
MAY CAUSE CANCER OF THE BOWEL.
Explanation of Carcinogenicity:ASBESTOS IS A KNOWN HUMAN CARCINOGEN.
Effects of Overexposure:FATIGUE AND SHORTNESS OF BREATH THAT GETS WORSE
WITH TIME AND EVENTUALLY BECOMES DISABLING.
Medical Cond Aggravated by Exposure:ASTHMA, EMPHYSEMA, AND TUBERCULOSIS
ARE ALL GENERALLY AGGRAVATED BY EXPOSURE TO ASBESTOS FIBERS.
* First Aid Measures *
First Aid:SUPPORTIVE CARE AND TREATMENT OF TRAUMA ARE THE ONLY FIRST
AID PROCEDURES SUITABLE FOR EXPOSURE TO ASBESTOS.
* Fire Fighting Measures *
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
* Accidental Release Measures *
Spill Release Procedures:VACUUM THE MATERIAL WITH A HEPA FILTERED
VACUUM. THE EQUIPMENT SHALL BE USED & EMPTIED SO AS TO MINIMIZE THE
RE-ENTRY OF ASBESTOS INTO THE WORKPLACE. OTHERWISE, WET THE
MATERIAL WITH WATER & SURFACTAN T AND THEN SHOVEL OR MOP UP
CONTAMINATION.
*Handling and Storage *
Handling and Storage Precautions:BRAKE SHOE IS NONFRIABLE & WILL NOT
SHED FIBERS IN NORMAL USE AND STORAGE.
Other Precautions:IF IT IS NECESSARY TO CUT OR DAMAGE THE BRAKE SHOE
WHILE INSTALLING IT, WEAR A RESPIRATOR AND PROTECTIVE CLOTHING.
USED BRAKE SHOES SHALL BE IDENTIFIED AND DISPOSED OF IN ACCORDANCE
WITH ALL LOCAL, ST ATE AND FEDERAL REGULATIONS.
* Physical/Chemical Properties *
HCC:N1
Boiling Pt:B.P. Text:NOT GIVEN
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:NOT GIVEN
Spec Gravity:1.4
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:NIL
Appearance and Odor:BLACK WOVEN MATERIAL, SOLID
Percent Volatiles by Volume:0 %
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:ASBESTOS DUST, TOXIC MATERIALS
* Disposal Considerations *
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
Control Measures
*
Product ID: PYROPLEX E.P. 2
Proprietary Ind: Y
*
Contractor Summary
*
*
Item Description Information
*
Item Name: GREASE
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EXPOSURE LIMIT FOR PROD: 5 MG/M3 OIL MIST (MFR). SKIN:
PROLONGED OR REPEATED SKIN CONTACT MAY CAUSE IRRITATION. EYE: SLIGHT
IRRITATION. INGESTION: RELATIVELY NON-TOXIC.
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
IRRIT PERSISTS,CALL PHYS. SKIN:REMOVE ANY CONTAM CLTHG & WASH SKIN THORO
W/SOAP & H*2O. INGEST:DO NOT INDUCE VOMIT;CALL PHYS IMMED. I NHAL:VAP
PRESS IS VERY LOW.VAP INHAL UNDER AMBIENT TEMP CNDTNS IS NOT NORM PROBLEM.IF
OVERCOME BY VAP FROM HOT PROD,ADMIN O*2,IF AVAIL.IF OVEREXPOS TO OIL MIST,
REMOVE FROM FURTHER EXPOS UNTIL(SUPDAT)
*
Handling and Disposal
*
Spill Release Procedures: RECOVER FREE PROD.ADD SAND, EARTH/OTHER SUITABLE
ABSORB MATL TO SPILL AREA.MIN BRTHG VAPS.MIN SKIN CONT.OPEN ALL WINDOWS &
DOORS.KEEP PROD OUT OF SEWERS & WATERCOURSES BY DIKING/IMPOUNDING. ADVISE
AUT H IF PROD HAS ENTERED/MAY ENTER SEWERS,(SUPDAT)
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: ASSURE CONFORMITY WITH ALL FEDERAL, STATE AND LOCAL
REGULATIONS.
Handling And Storage Precautions: KEEP CONTAINERS AND STORAGE CONTAINERS CLOSED
WHEN NOT IN USE. DO NOT STORE NEAR HEAT, SPARKS, FLAME OR STRONG OXIDANTS.
Other Precautions: USE PRODUCT WITH CAUTION AROUND HEAT, SPARKS, PILOT LIGHTS,
STATIC ELECTRICITY AND OPEN FLAME.
*
Fire and Explosion Hazard Information
*
Flash Point Method: COC
Lower Limits: 0.9%
Upper Limits: 7%
Extinguishing Media: FOAM, H*2O SPRAY (FOG), DRY CHEM, CARBON DIOXIDE & VAP
LIQ TYPE EXTING AGENTS MAY ALL BE SUITABLE FOR TYPE OF PRODUCT.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP(FP
N).PLAN FIRE PROT & RESPONSE STRATEGY THRU CONSULTATION W/LOC FIRE PROT
AUTH/APPROP SPECIALISTS.
Unusual Fire/Explosion Hazard: "EMPTY" CNTNRS RETAIN RESIDUE (LIQ &/OR VAP)
& CAN BE DANGEROUS. DO NOT PRESS, CUT, WELD, BRAZE,SOLDER,DRILL,
GRIND/EXPOS SUCH CNTNRS TO HEAT,FLAME,
*
*
Respiratory Protection: NO SPECIAL REQUIREMENTS UNDER ORDINARY CONDITIONS OF
USE AND WITH ADEQUATE VENTILATION. WEAR NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN (FP N).
Ventilation: NO SPECIAL REQUIREMENTS UNDER ORDINARY CONDITIONS OF USE. GEN VENT
SUFF TO KEEP AIRBORNE CONC BELOW EXPOS LIMITS (FP N).
Other Protective Equipment: NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices: REMOVE CONTAM CLTHG;LAUNDER/DRY CLEAN BEFORE REUSE.
REMOVE CONTAM SHOES & THORO CLEAN BEFORE REUSE; DISCARD IF (SUPDAT)
Supplemental Safety and Health: FIRST AID PROC: EXCESSIVE MIST OIL CNDTN
SUBSIDES. SPILL PROC: WATERCOURSES/EXTENSIVE LAND AREAS. HYGIENE
PRACT:OIL-SOAKED. CLEAN SKIN THORO AFTER CONT, BEFORE BREAKS & MEALS,
& AT END OF WORK PERIOD.PROD IS READILY REMOVED FROM SKIN BY WATERLESS
HAND CLEANERS FOLLOWED BY WASHING THOROUGHLY WITH SOAP AND WATER.
*
Physical/Chemical Properties
*
Vapor Pres: NEGLIGIBLE
Vapor Density: >AIR
Evaporation Rate & Reference: NEGLIGIBLE
Solubility in Water: NEGLIGIBLE,
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume: NEGLIG
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: AVOID HEAT, OPEN FLAMES.
Materials To Avoid: OXIDIZING MATERIALS.
Hazardous Decomposition Products: UNDER FIRE CNDTNS:FUMES,SMOKE,CARBON
MONOXIDE,SULFUR OXIDES,ALDEHYDES & OTHER DECOMP PRODS,IN CASE OF INCOMPLETE
COMBUST
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
Transportation Information
*
Product ID: PYROPLEX E.P. 2
Multiple KIT Number: 0
Review IND: Y
Additional Data: NOT REGULATED FOR TRANSPORTATION
*
Detail DOT Information
*
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail IMO Information
*
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
*
Detail IATA Information
*
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail AFI Information
*
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
HAZCOM Label
*
Product ID: PYROPLEX E.P. 2
Company Name: DRYDEN OIL CO INC
Label Required IND: Y
Status Code: C
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: DO NOT STORE NEAR HEAT, SPARKS, FLAME OR STRONG
OXIDANTS. ACUTE: EYE: SLIGHT IRRITATION. INGESTION: RELATIVELY NON-TOXIC.
CHRONIC: SKIN:PROLONGED OR REPEATED SKIN CONTACT MAY CAUSE IRRITATION.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE WELD FUME RESPIRATOR OR AIR SUPPLIED
RESPIRATOR WHEN CUTTING, GRINDING OR WELDING IN A CONFINED SPACE OR
WHERE LOCAL EXHAUST OR GENERAL VENTILATION DOES NOT KEEP EXPOSURE
BELOW RECOMMENDED LIMITS. MONITOR THE AIR QUALITY INSIDE THE
WELDER'S HELMET, IF WORN, AND/OR THE WORKER'S BREATHING ZONE TO
DETERMINE IF A RESPIRATOR (SUPPLEMENTAL SAFETY AND HEALTH)
Ventilation:USE ENOUGH VENTILATION WHEN CUTTING, GRINDING OR WELDING TO
KEEP DUST, FUMES AND GASES FROM THE WORKER'S BREATHING ZONE AND
(SUPPLEMENTAL SAFETY AND HEALTH)
(WORK HYGENIC PRACTICES)
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
CUTTING, GRINDING OR WELDING. DO NOT EXPOSE SKIN TO (SUPPLEMENTAL
SAFETY AND HEALTH)
OR WELDING. IN ADDITION, WHEN HOT CUTTING OR WELDING, WEAR WELDING
HELMET OR FACE SHIELD WITH FILTER LENS. SELECT WELDING LENS SHADE
FROM AWS PUB F2.2.
Supplemental Safety and Health
RESP PROT (CONT): IS REQUIRED AND THE TYPE NEEDED. USE ONLY NIOSH
APPROVED RESPIRATORS. VENTILATION (CONT): GENERAL AREA. KEEP
EXPOSURE BELOW THE LIMITS SPECIFIED IN (INGREDIENTS AND REACTIVITY)
SE CTIONS. OTHER PROT EQUIP (CONT): RADIATION WHEN HOT CUTTING
OR WELDING. PROVIDE PROTECTIVE SCREENS TO SHIELD OTHERS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:IRON (FE)
Fraction by Wt: BALANCE
OSHA PEL:NONE
ACGIH TLV:NONE
Ingred Name:CHROMIUM (CR)
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:NICKEL (NI)
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:SILICON
= Wt:4.2
Ingred Name:ALUMINIUM
= Wt:1.7
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:THIS PRODUCT POSES NO HEALTH HAZARD AS
SHIPPED BUT MAY POSE A HEALTH HAZARD DURING USE. ELECTRIC ARC
WELDING RAYS CAN INJURE EYES AND BURN SKIN. DUST, FUMES AND GASES
CAN BE DANGEROUS TO YOUR HEALTH. LUNG DAMAGE MAY RESULT FROM
OVEREXPOSURE. SECTIONS (INGREDIENTS AND REACTIVITY) LIST SPECIFIC
HAZARDOUS INGREDIENTS, REACTION PRODUCTS AND OSHA PEL'S AND ACGIH
TLV'S. PRIMARY ROUTE OF ENTRY: FUMES, GASES AND DUST CAN BE A
HEALTH HAZARD THRU INHALATION. ACUTE EXPOSURE: SHORT TERM EXPOSURE
TO WELDING FUMES, GASES OR DUST MAY RESULT IN DISCOMFORT SUCH AS
DIZZINESS, NAUSEA, FEVER, DRYNESS AND/OR (S IGNS AND SYMPTOMS OF
OVEREXPOSURE)
Effects of Overexposure:HEALTH HAZARDS ACUTE AND CHRONIC (CONT):
IRRITATION OF NOSE, THROAT AND EYES. SKIN SENSITIVITY MAY ALSO BE
NOTED. ACUTE EXPOSURE CAN RESULT IN THE SAME SYMPTOMS EXCEPT TO A
GREATER DEGREE AS WELL AS W ATERY EYES, HEADACHE, BREATHING
DIFFICULTY, FREQUENT COUGHING AND/OR CHEST PAINS. SOME TOXIC GASES
MAY CAUSE PULMONARY EDEMA, ASPHYXIATION AND EXCESSIVE EXPOSURE CAN
BE FATAL. CHRONIC EXPOSURE: CHRON IC EXPOSURE MAY RESULT IN
NEUROLOGICAL DAMAGE, LUNG FIBROSIS, PNEUMONCONIOSIS AND OTHER LUNG
DISEASES. NICKEL AND CHROMIUM ARE CONSIDERED POSSIBLE CARCINOGENS
(TOXICOLOGICAL INFO)
Medical Cond Aggravated by Exposure:SOME WORKERS MAY EXPERIENCE
DISCOMFORT AT CONCENS BELOW THE TLV & OTHERS MAY BE AFFECTED BY
PRE-EXISTING CNDTNS OR OTHER OCCUPATIONAL ILLNESS BECAUSE OF WIDE
VARIATION IN INDIVIDUAL SUSCEPTIBILITIES.
* First Aid Measures *
First Aid:IN CASE OF ELECTRIC SHOCK, TURN OFF POWER PRIOR TO REMOVAL
FROM EXPOSURE AREA AND ADMINISTRATION OF FIRST AID. INHALATION:
REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT ADMINISTER OXYGEN.
IF NOT BRE ATHING BEGIN ARTIFICIAL RESPIRATION. IF NO DETECTABLE
PULSE BEGIN EXTERNAL HEART MASSAGE. SKIN: WASH AFFECTED AREA WITH
SOAP AND WATER. EYES: FLUSH WITH LARGE AMOUNTS OF FRESH WATER FOR
* Fire Fighting Measures *
Flash Point:NONFLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONFLAMMABLE; HOWEVER, ARCS, SPARKS AND
MOLTEN METAL CAN IGNITE FLAMMABLES AND COMBUSTIBLES OR CAUSE
EXPLOSIONS.
* Accidental Release Measures *
Spill Release Procedures:CLEAN UP ANY GRINDING DUST OR WASTE RESIDUES
AND PLACE IN SUITABLE DEPARTMENT OF TRANSPORTATION (DOT) APPROVED
CONTAINERS AND DISPOSE OF IN FULL COMPLIANCE WITH FEDERAL, STATE
AND LOCAL REGULATIONS. A VOID INHALATION AND SKIN EXPOSURE.
* Physical/Chemical Properties *
HCC:T6
Appearance and Odor:BARE FILLER METALS ARE SOLID WIRE.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:WELDING AND HOT CUTTING FUMES AND
GASES CANNOT BE CLASSIFIED SIMPLY. THEIR COMPOSITION AND QUANTITY
ARE DEPENDENT ON THE METAL BEING WELDED, THE PROCEDURES, PROCESSES
AND TYPE OF WIRE (ECOLOGICAL INFO)
* Toxicological Information*
Toxicological Information:N/P. SIGNS AND SYMPTOMS OF
OVEREXPOSURE (CONT): FOR THIS CLASSIFICATION WERE FROM OPERATIONS
OTHER THAN WELDING OF CHROMIUM OR NICKEL. THERE IS CONSIDERABLE
CONTROVERSY ON THE EXTENT OF RESPIRA TORY CANCER PROBLEMS DUE TO
NICKEL AND CHROMIUM. NEVERTHELESS EXPOSURES MUST BE MAINTAINED
BELOW THE LEVELS SPECIFIED IN (INGREDIENTS AND REACTIVITY)
SECTIONS.
* Ecological Information *
Ecological:N/P. HAZARDOUS DECOMPOSITION PRODUCTS (CONT): OR
ELECTRODES USED. OTHER INFLUENCING FACTORS ARE THE PRESENCE OF
CONTAMINENTS IN THE ATMOSPHERE. DECOMPOSITION PRODUCTS FROM THE
WELDING OR CUTT ING OPERATION INCLUDE THOSE FROM THE
VOLATILIZATION, REACTION AND/OR OXIDATION OF THE MATERIALS IN
(INGREDIENTS) SECTION AND MAY INCLUDE OXIDES OF THE METALS,
CHROMATES AND COMPLEX METALLICS. GASEOUS REACTION PRODUCTS MAY
INCLUDE CARBON MONOXIDE, OZONE AND NITROGEN OXIDES. CHLORINATED
SOLVENTS MAY BE DECOMPOSED INTO TAXIC GASES SUCH AS PHOSGENE. WHEN
ELECTRODES ARE CONSUMED, THE FUME AND GAS DECO MPOSITION PRODUCTS
(TRANSPORT INFO)
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN FULL COMPLIANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS.
* MSDS Transport Information *
Transport Information:N/P. ECOLOGICAL INFO (CONT): GENERATED
ARE DIFFERENT IN FORM FROM THE INGREDIENTS LISTED IN (INGREDIENTS)
SECTION. NEW COMPOUNDS NOT IN THE ELECTRODES MAY FORM. THE KNOWN
GASES AND FUMES THAT MAY FORM DURING WELDING OR HOT CUTTING AND
THEIR EXPOSURE LIMITS ARE NOTED IN THE FOLLOWING TABLE: ALUMINUM
MG/M3. CHROMIUM (CHROMATES), CAS # VARIES WITH COMPOUND, PEL
* Regulatory Information *
SARA Title III Information:N/P. TRANSPORT INFO (CONT): COBALT
PEL: 0.5 MG/M3, TLV: 0.1 MG/M3. TUNSTEN (W) (SOLUABLE), CAS #
DIOXIDE, PEL CEILING: 9 MG/M3, TLV: 5.6 MG/M3. (FEDERAL REGS)
Federal Regulatory Information:N/P. SARA III (CONT): OZONE,
THE LIMIT FOR WELDING FUMES NOT OTHERWISE CLASSIFIED IS 5 MG/M3.
SOME ELEMENTS OR COMPOUNDS WILL EXCEED THEIR PEL'S / TLV'S BEFORE
THE TOTAL FUMES EXCEED 5 MG/M3.
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:USE LOCAL EXHAUST VENTILATION.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NORMAL PRACTICES.
Supplemental Safety and Health
NONE
* Product Identification *
Product ID:XL DEVELOPER
* Composition/Information on Ingredients *
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES-MAY CAUSE SEVERE EYE IRRITATION.
LONG TERM EXPOSURE TO HYDROQUI MAY CAUSE VISUAL IMPAIRMENT WITH
LIGHT SENSITIVITY.SKIN-HYDROQUI MAY CAUSE LOSS OF SKIN
PIGMENT AND ALLERGIC SKIN REACTIO NS IN SOME INDIVIDUALS.
INHALATION-MAYCAUSE RESPIRATORY SYSTEM IRRITATION. INGESTION-MAY
CAUSE SEVERE ASTHMA ATTACK.
Effects of Overexposure:MAY CAUSE SEVERE ASTHMATIC REACTIONS IN SOME
INDIVIDUALS EXPOSED TO SMALL QUANTITIES. LIGHT SENSITIVITY UPON
LONG TERM EXPOSURE TO HYDROQUI.
Medical Cond Aggravated by Exposure: SPECIFIED BY MANUFACTURER.
* First Aid Measures *
A PHYSICIAN. SKIN-RINSE WITH WATER. INHALATION-REMOVE TO FRESH
AIR. INGESTION-DRINK TWO GLASSES OF MILK OR WATER. CONTACT A
PHYSICIAN. D O NOT INDUCE VOMITING.
* Fire Fighting Measures *
Flash Point:NON-FLAMMABLE
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICALS.
Fire Fighting Procedures:FIREFIGHTERS SHOULD USE SELF-CONTAINED
BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:
* Accidental Release Measures *
Spill Release Procedures:SMALL VOLUME SPILLS OR WASTE CAN GENERALLY BE
FLUSHED TO SEWER ALONG WITH OTHER FACILITY WASTES. MOST SANITARY
SEWER DISTRICTS LIMIT THE PH OF EFFLUENT FROM A FACILITY TO BELOW
ACID.
Neutralizing Agent:SODIUM BISULFATE, SULFAMIC ACID, OR VINEGAR.
*Handling and Storage *
Handling and Storage Precautions:AVOID BREATHING MIST. DO NOT TAKE
INTERNALLY. KEEP CONTAINER CLOSED WHEN NOT IN USE. KEEP OUT OF
REACH OF CHILDREN.
Other Precautions:
* Physical/Chemical Properties *
HCC:B1
Vapor Density:LIKE WATER
Viscosity:5.0 CPS
Evaporation Rate & Reference:1 (NO REFERENCE GIVEN)
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR AMBER, MILD SOAP ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED
Work Hygienic Practices:OBSERVE NORMAL CARE FOR WORKING WITH CHEMICALS.
Supplemental Safety and Health
* Product Identification *
Product ID:PRISMA SHIELD
* Composition/Information on Ingredients *
Ingred Name:NON-HAZARDOUS FOR INGREDIENTS
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: ALLERGIC RESPONSE, REDNESS,
IRRITATION, SENSITIVE, & DERMATITIS. INGESTION: SEVERE ALLERGIC
RESPONSE MAY RESULT IN BREATHING DIFFICULTIES.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: ALLERGIC RESPONSE, REDNESS, IRRITATION,
SENSITIVE, & DERMATITIS. INGESTION: SEVERE ALLERGIC RESPONSE MAY
RESULT IN BREATHING DIFFICULTIES.
Medical Cond Aggravated by Exposure:SKIN
ALLERGIES/SENSITIVE/DERMATITIS.
* First Aid Measures *
First Aid:INGESTION: CONTACT PHYSICIAN. SKIN: WASH W/SOAP & WATER. EYE:
* Fire Fighting Measures *
Extinguishing Media:SAND, FOAM, CO2, DRY CHEMICALS
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS & FULL
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:DURING A FIRE, IRRITATING/TOXIC GASES MAY
BE PRESENT FROM THE DECOMPOSITION/COMBUSTION PRODUCTS.
* Accidental Release Measures *
Spill Release Procedures:SCOOP UP BULK MATERIAL & PLACE IN LABELED
PLASTIC OR METAL CONTAINER.
*Handling and Storage *
AWAY FROM FOOD & BEVERAGES.
Other Precautions:OBSERVE NORMAL CARE FOR WORKING WITH CHEMICALS.
* Physical/Chemical Properties *
Solubility in Water:INSOLUBLE
Appearance and Odor:BRIGHT COLORED RESIN WITH SWEET ACRYLATE ESTER
ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF UNDER CONDITIONS ACCORDING TO
FEDERAL, STATE & LOCAL ENVIRONMENTAL CONTROL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:DO NOT BREATHE VAPS,SPRAY MIST/SANDING DUST.
WHEN SPRAY APPLIED IN OUTDOOR/OPEN AREAS & DURING SANDING/GRINDING
OPS, USE NIOSH/MSHA APPRVD MECH FILTER RESP TO REMOVE SOLID
Ventilation:PROVIDE GENL DILUTION/LOCAL EXHAUST VENT IN VOL & PATTERN
Other Protective Equipment:SOLVENT IMPERMEABLE CLOTHING & BOOTS TO
PREVENT SKIN CONTACT ARE RECOMMENDED.
Work Hygienic Practices:REMOVE & WASH SOILED CLOTHING BEFORE REUSE.
WASH HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health
TRADE NAME:EPOXY COATING, MEDIUM GREEN BASE. FIRE FIGHT:IF EXPOS TO
FIRE/EXTREME HEAT, WATER SHOULD BE USED TO COOL CLSD CNTNR & PVNT
PRESS BUILD UP/POSS AUTO-IGNIT. EXPLO HAZ:WELDING/CUTTING TORCH ON
/NEAR CNTNR(EVEN EMPTY) AS PROD/ITS RESIDUE MAY IGNIT. DURING EMER
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:CRYSTALLINE SILICA (PC);(SILICON DIOXIDE, AMORPHOUS)
Fraction by Wt: <0.5%
OSHA PEL:0.1 MG/M3(RESP)(MFR)
ACGIH TLV:0.1 MG/M3(RESP)(MFR)
Ingred Name:EPOXY RESIN
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SOLVENT NAPHTHA(PETROLEUM),LIGHT AROMATIC; (HIGH FLASH
OSHA PEL:N/K
Ingred Name:HYDROCARBON RESIN
OSHA PEL:N/K
ACGIH TLV:N/K
Fraction by Wt: <5%
ACGIH TLV:5MG(FE); M3FUME,B2
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (MAGNESIUM
SILICATE)
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:0.2 FIBERS/CC
MG/KG (ORAL, RAT).
Fraction by Wt: <5%
Ingred Name:SILICATE,MICA; (MICA)
ACGIH TLV:3 MG/M3 RDUST
Ingred Name:BUTYL ALCOHOL; (N-BUTYL ALCOHOL) (SARA III). VP: 4.2.
Fraction by Wt: 5%
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:COMPLETE
Ingred Name:ACETIC ACID,2-METHOXY-1-METHYLETHYL ESTER;(PROPYLENE GLYCOL
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPP DATA: HAZ. SYMPS MAY NOT BE IMMED APPARENT. OBTAIN MED
ATTN.
Ingred Name:HAZ DECOMP: DERIVATIVES, TRACES OF TDI, AND LOW MOLECULAR
WEIGHT ORGANIC FRAGMENTS.
Ingred Name:FIRST AID PROC: DO NOT INDUCE VOMITING. ASPIRATION OF
CONCENTRATING & INHALING THE CONTENTS MAY BE HARMFUL OR FATAL.
Ingred Name:OTHER PRECS: CONVERTER PORTIONS WILL HAVE HAZARDS OF BOTH
COMPONENTS. OBSERVE ALL APPLICABLE PRECAUTIONS.
Ingred Name:RESP PROT: IN RESTRICTED VENT AREAS, WEAR NIOSH/MSHA APPRVD
WELDING,BRAZING & SANDING MATL COATED W/THIS PRODUCT.
Ingred Name:VENT: & HLTH STDS IN THE MIXING, APPLICATION & CURING AREAS
FROM LOWER LEVELS OF THE WORK AREA. ELIM ALL IGNIT SOURCES.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: IRRIT OF RESP TRACT;
HDCH, NAUS, DIZZ, WEAK & FATIGUE. EXTREME EXPOS CAN RSLT IN UNCON &
EVEN RESP ARREST. MAY CAUSE ALLERGIC RXN. OVEREXP MAY CAUSE PERM
LUNG DMG. SKIN/EYE: CAUSES EYE/S KIN IRRIT. MAY BE HARMFUL IF
ABSORB THRU SKIN. INGEST: CAN CAUSE STOMACH &/INTESTINAL IRRIT,
NAUS,VOMIT(EFTS OF OVEREXP)
Explanation of Carcinogenicity:CRYSTALLINE SILICA: IARC GROUP 2A, VOL
Effects of Overexposure:HLTH HAZ: & DIARRHEA. CHRONIC: RPTS HAVE ASSOC
RPTD & PRLNGD OCCUP OVEREXP TO SOLVENTS W/PERMANENT BRAIN & CNS
DAMAGE. PRLNG/RPTD BREATHING OF SPRAY MIST &/SANDING DUST OVER A
PERIOD OF YEARS MAY CAUS E DISEASE OF THE LUNGS. CONTAINS
CRYSTALLINE SILICA WHICH CAN CAUSE LUNG DMG & CANCER.
Medical Cond Aggravated by Exposure:NONE WHEN USED IN ACCORDANCE WITH
SAFE HANDLING & USE INFORMATION.
* First Aid Measures *
First Aid:INHAL: IF EXPERIENCE DFCLT BRTHG, LEAVE AREA TO OBTAIN FRESH
AIR. IF CONTINUED DFCLTY IS EXPERIENCED, GET MD ASSIST IMMED. IF
BRTHG CEASES, RESTORE USING APPRVD CPR TECHNIQUES & GET MD IMMED.
ASSIST. SKIN: WASH AFFECTED AREAS W/SOAP & WATER. REMOVE SOILED
CLTHG. GET MED ASSIST IF IRRIT PERSISTS. INGEST: CONSULT MD
* Fire Fighting Measures *
Flash Point Method:SCC
Lower Limits:1%
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM OR OTHER NFPA APPROVED
METHOD FOR TREATING CLASS B FIRE.
Fire Fighting Procedures:SUMMON PROFESSIONAL FIRE FIGHTERS. WEAR
NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP. WATER SPRAY MAY BE
INEFTIVE. IF WATER IS USED, FOG NOZZ PREF.(SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT/ELECT EQUIP/SPARKS/FLAME. DUE TO PRESS BUILD-UP, CLSD CTNRS
EXPOS TO EXTREME HEAT MAY EXPLODE. NEVER USE(SUPP DATA)
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT(FLAMES,HOT SURFS,
& ELECT, STATIC/FRICTIONAL SPARKS). PVNT BRTHG OF VAPS. VENT AREA.
CNTN SPILLED MATL & REMOVE W/INERT ABSORB & NON-SPRAKING TOOLS.
STORE IN CLSD CNTNR UNT IL PROPERLY DISP OF.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT & SPARKS. DO NOT
SMOKE. PVNT BUILD-UP OF VAPS BY MAINT CONTINUOUS FLOW OF FRESH AIR.
Other Precautions:STORE LGE QTYS IN BUILDINGS TO COMPLY W/OSHA
TO BOTTLES/OTHER UNLABELLED CNTNRS. DO NOT REUSE EMPTY CNTNRS. IF
* Physical/Chemical Properties *
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY CAUSE TOX FUMES WHEN HEATED TO
DECOMP. FUMES MAY CONTAIN CARBON MONOXIDE, CARBON DIOXIDE, PHENOL
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE &
FEDERAL REGULATIONS. INCINERATE ONLY IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINER.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:ADEQ VENT IS REQUIRED. THIS PROD CONTAINS
ISOCYANATES. USE NIOSH APPRVD POS PRESS AIR SUPPLY RESP. SEE SFTY
EQUIP SUPPLIER FOR EVALUATION & REC. IN CASE WHERE NO MONITORING
Ventilation:PROVIDE SUFFICIENT VENT TO KEEP VAP CONC BELOW GIVEN TLV
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING THE
WASHROOM. LAUNDER CLOTHING BEFORE REUSE.
Supplemental Safety and Health
EXPLO HAZ: SURF REQUIRES SPECIAL PREC. DURING EMER CNDTNS, OVEREXP TO
DECOMP PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE IMMED APPARENT.
OBTAIN MED ATTN. EFTS OF OVEREXP: BE HARMFUL/FATAL. RPTS HAVE AS
SOC RPTD & PRLNG OCCUP OVEREXP TO SOLVSW/PERM BRAIN & NERV SYS DMG.
AROMATIC HYDROCARBONS HAVE BEEN SHOWN IN (ING 9)
* Product Identification *
CAGE:AKZNB
CAGE:AKZNB
* Composition/Information on Ingredients *
Fraction by Wt: 1.9%
Ingred Name:ACETIC ACID, BUTYL ESTER; (N-BUTYL ACETATE) (CERCLA) VP:
Ingred Name:ISOCYANIC ACID, HEXAMETHYLENE ESTER, POLYMERS; (ALIPHATIC
POLYISOCYANATE RESIN)
OSHA PEL:N/K
ACGIH TLV:0.5 MG/M3 (MFR)
Ingred Name:HEXANE, 1,6-DIISOCYANATO-; (HEXAMETHYLENEDIISOCYANATEMONO)
OSHA PEL:N/K
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:AROMATIC SOLVENT
Fraction by Wt: 1-5%
OSHA PEL:N/K
Ingred Name:ISOCYANIC ACID, METHYLENE
(3,5,5-TRIMETHYL-3,1-CYCLOHEXYLENE)ESTER; (ISOPHOMORE DIISOCYANATE
Ingred Name:SUP DAT: ANIMAL STUDIES TO CAUSE ADVERSE EFTS ON BLOOD &
Ingred Name:ING 9: CAUSING CARD ARRHYS. 2-BUTOXYETHYL ACETATE HAS BEEN
Ingred Name:VENT: HEATING. REMOVE DECOMPOSITION PRODUCTS FORMED DURING
WELDING OR FLAME CUTTING OF SURFACES COATED W/THIS PRODUCT.
Ingred Name:OTHER PROT EQUIP: RESIST APRON, BOOTS/OTHER CLTHG IF NEEDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: NASAL & RESP IRRIT,
DIZZ, WEAK, FATG, NAUS, HDCH, POSS UNCON, CHEM PNEUMIT, CNS DEPRESS
& EVEN ASPHY. SKIN: EXTRACTION OF NATRL OILS W/RSLTG DRY SKIN,
IRRIT, REDNESS & DERM. EYES: IRRIT, REDNESS, PAIN, BLURRED VISION,
SENSATION OF SEEING HALOS AROUND LIGHTS. INGEST: GI IRRIT, NAUS,
VOMIT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: & DIARR. CHRONIC: INHAL: DELAYED LUNG
DMG, KIDNEY, LIVER, & CARD DISORDERS, RED BLOOD CELL & LEUKOCYTE
DISORDERS WHICH MAY RSLT IN ANEMIA. SKIN: SENSIT MAY OCCUR. EYES:
EYE DMG. INGEST: KIDN EY & BLOOD SYS DMG. OTHER HLTH EFTS:
INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING & INHALING
CONTENTS MAY (SUP DAT)
Medical Cond Aggravated by Exposure:ISOCYANATE SENSITIZATION, SKIN
DISORDERS, EYE DISORDERS.
* First Aid Measures *
First Aid:INHALATION: MOVE TO FRESH AIR, GIVE ARTIFICIAL RESPIRATION IF
NECESSARY. SKIN: WASH WITH SOAP AND WATER, NOT SOLVENT. EYES: FLUSH
ONE O R TWO GLASSES OF WATER TO DILUTE. DO NOT INDUCE VOMITING.
CONSULT MD OR POISON CONTROL CENTER IMMEDIATELY. TREAT
SYMPTOMATICALLY.
* Fire Fighting Measures *
Lower Limits:0.9%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICALS.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER SHOULD BE USED TO COOL CONTAINERS EXPOSED TO
FIRE.
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY CLSD, ISOLATE FROM
HEAT, ELEC EQUIP, SPKS & OPEN FLAME. CLSD CONTRS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. APPLICATION TO HOT (SUP DAT)
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
BREATHING VAPORS, VENTILATE CONFINED AREA. DIKE TO REDUCE EXTENT OF
SPILL. REMOVE WITH INERT ABSORBENT USING NON-SPARKING TOOLS. IF
NECESSARY REPORT TO APPLICABLE GOVERNMENT AGENCY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE CONTRS OUT OF SUN & AWAY FROM
HEAT, SPARKS, & OPEN FLAMES. CLOSE ALL CONTRS AFTER EACH USE.
CONSULT NFPA & LOCAL CODES FOR ADDITIONAL STOR REQS.
Other Precautions:USE APPROVED BONDING AND GROUNDING PROCEDURES.
OBSERVE LABEL PRECAUTIONS. KEEP CLOSURES TIGHT AND CONTAINER
UPRIGHT TO PREVENT LEAKAGE. AVOID BREATHING SANDING DUST. DO NOT
WELD OR FLAME CUT ON EMPTYDRUM.
* Physical/Chemical Properties *
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:CLEAR LIQUID, ORGANIC ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ALKALIS, OXIDIZERS, ALKALI METALS, WATER, AMINES, NITRIC ACID, SODIUM
HYPOCHLORITE, METAL COMPOUNDS.
Stability Condition to Avoid:OPEN FLAME, HEAT, SPARKS, MOISTURE.
Hazardous Decomposition Products:OXIDES OF CARBON AND NITROGEN, VARIOUS
HYDROCARBONS, HYDROGEN CYANIDE, HEXAMETHYLENE DIISOCYANATE (HDI).
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE & LOCAL
POLLUTION REQUIREMENTS. IN ADDITION, RAGS, SPRAY BOOTH FILTERS,
PAINT SUITS, EMPTY CANS, ETC, CONTAM W/PRODUCT MAY BE HAZARDOUS
WASTE. DETERMINE WHETHER CONTAMI NATED ITEMS ARE HAZARDOUS &
DISPOSE OF AS APPROP.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF SPRAYING, USE AN APPROPRIATE NIOSH/MSHA
APPROVED RESPIRATOR SHOULD BE WORN. WHERE ABRADING OF CURED
MATERIAL LEADS OF RESPIRABLE &/NUISANCE DUST, AN APPROPRIATE
NIOSH/MSHA APPROVED RESPIRATOR SHOUL D BE WORN.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:POLY VINYL CHLORIDE, EYEWASH STATION, SAFETY
BOOTS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WHEN USING, DON'T EAT, DRINK/SMOKE.
Supplemental Safety and Health
WASH HANDS W/SOAP & WATER AFTER HANDLING THIS PRODUCT.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:TITANIUM DIOXIDE, TIO2 (SUSPECTED ANIMAL CARCINOGEN, IARC
Fraction by Wt: 3-7%
ACGIH TLV:0.2 MG/CUM
Fraction by Wt: 1-5%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM FUME
Ingred Name:ZIRCONATE(2-),BIS(CARBONATO(2-)-O)DIHYDROXY-,DIAMMONIUM
Fraction by Wt: 1-5%
Ingred Name:PROPANOIC ACID, 2-METHYL, MONOESTER
W/2,2,4-TRIMETHYL-1,3-PENTANEDIOL, TEXANOL(ESTER ALCOHOL)
Fraction by Wt: 1-5%
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION & DERMATITIS. EYES:
IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
Medical Cond Aggravated by Exposure:SKIN & EYE CONDITIONS.
* First Aid Measures *
EXCESS W/A CLEAN CLOTH & WASH THOROUGHLY W/SOAP & WATER. INGESTION:
DON'T INDUCE VOMITING. RINSE MOUTH W/WATER & DRINK PLENTY OF WATER.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING & USE SCBA TO PROTECT
AGAINST TOXIC FUMES EVOLVED. WEAR FULL BUNKER GEAR IN EXTREME
CASES. USE SAND TO CONTAIN BURNING MATERIAL.
Unusual Fire/Explosion Hazard:NON-FLAMMABLE, IF INVOLVED IN A FIRE
PRODUCT MAY CONTRIBUTE TO COMBUSTIBLE MATERIAL. DECOMPOSITION &
COMBUSTION PRODUCTS MAY BE HAZARDOUS.
* Accidental Release Measures *
Spill Release Procedures:ABSORB W/AN INERT MATERIAL (EARTH/SAND). SWEEP
UP, PLACE INTO SUITABLE LABELLED CONTAINERS, SEAL & DISPOSE OF
PROPERLY. FLUSH AREA W/DETERGENT & WATER.
*Handling and Storage *
Handling and Storage Precautions:CONTAINERS SHOULD BE STORED UNDER
COOL, DRY CONDITIONS. EMPTY CONTAINERS WILL RETAIN RESIDUE & MAY BE
DANGEROUS.
Other Precautions:AVOID CONTACT W/SKIN & EYES. OVERHEATING MAY CAUSE
CONTAINERS TO RUPTURE. CHECK ALL CONTAINERS FOR LEAKS AT REGULAR
INTERVALS & BEFORE USE.
* Physical/Chemical Properties *
Solubility in Water:MISCIBLE
Appearance and Odor:WHITE/GRAY THIXOTROPIC LIQUID W/AMMONIACAL ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS & ACIDS
Stability Condition to Avoid:OVERHEATING, ELEVATED TEMPS.
Hazardous Decomposition Products:GASEOUS COMBINATIONS OF CARBON,
HYDROGEN, NITROGEN & OXYGEN MAY OCCUR AT ELEVATED TEMPS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
Control Measures
*
*
Contractor Summary
*
*
Ingredients
*
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: INHAL: EXCESS INHAL OF VAPORS CAN CAUSE NASAL &
RESPIRATORY IRRIT, DIZZINESS, WEAKNESS, FATIGUE, NAUS, HDCH, POSSIBLE UNCON
& EVEN ASPHY. EYE CONT: CAN CAUSE SEV IRRIT, REDNESS, TEARING, BLURRE D
VISION. INGEST: CAN CAUSE GI IRRIT, NAUS, VOMIT, DIARR. SKIN CONT: CAN CAUSE
IRRIT FOR SOME PERSONS. (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: CHRONIC: REPORTS HAVE ASSOC RPTD
& PRLNGD OCCUP OVEREXPOSURE TO SOLVS W/PERM BRAIN & NERV SYS DAMAGE.
SEVERE OVEREXPOSURE IN LAB ANIMALS HAS ALSO CAUSED LIVER ABNORM & DAMAGE
TO KIDNEYS, LUN GS, & SPLEEN, HEART & ADRENALS. INTENTIONAL MISUSE BY
DELIB CONCENTRATING & INHALING CONTENTS MAY BE HARMFUL OR FATAL.
Medical Cond Aggravated By Exposure: GENERALLY AGGRAVATED BY EXPOSURE - CAN
CAUSE RESPIRATORY AND/OR SKIN REACTION.
First Aid: INHAL: REMOVE TO FRESH AIR. IF BRTHG IS DFCLT, ADMIN OXYG. IF BRTHG
IS STOPPED, GIVE ARTF RESP & SEEK MED HELP. EYE: FLUSH W/WATER FOR AT LST
MATL INTO LUNGS CAN CAUSE PNEUM, WHICH CAN BE FATAL). KEEP PERSON WARM, QUIET
& GET MED ATTN/POIS CTL CTR. SKIN: WASH W/SOAP & WATER OR VARIOUS
HAND CLEANERS & WASH CLOTHING.
*
Handling and Disposal
*
Spill Release Procedures: ELIMINATE ALL IGNITION SOURCES. VENTILATE AREA.
ABSORB LIQUID ON PAPER. VERMICULITE. FLOOR ABSORBENT, OR OTHER ABSORBENT
MATERIAL AND TRANSFER TO A CLOSED CONTAINER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: MATERIAL COLLECTED ON ABSORBENT MATERIAL MAY BE
DEPOSITED IN A POSTED TOXIC SUBSTANCE LANDFILL IN ACCORDANCE WITH LOCAL,
STATE, AND FEDERAL REGULATIONS.
DIRECT SUNLIGHT, OR NEAR HEAT OR OPEN FLAMES. DO NOT PUNCTURE OR INCINERATE.
Other Precautions: STORE LARGE QUANTITIES IN BUILDING PROTECTED FOR STORAGE OF
FLAMMABLE LIQUIDS.
*
Fire and Explosion Hazard Information
*
Flash Point Method: TCC
Lower Limits: 1.0%
Extinguishing Media: ALCOHOL FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures: WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). IF WATER IS USED, FOG NOZZLES ARE PREFERABLE.
Unusual Fire/Explosion Hazard: VAPS ARE HVR/AIR & MAY TRAVEL ALONG
GROUND/MAY BE MOVED BY VENT & IGNITED BY PILOT LIGHTS, OTHER FLAMES,
SPARKS, HEATERS, SMKNG, ELECTRIC MOTORS/OTHER (SUPDAT)
*
*
Respiratory Protection: FOR CASUAL OCCASIONAL USE-TO AVOID BRTHG VAPS/SPRAY
MIST, OPEN WINDOWS & DOORS/USE OTHER MEANS TO ENSURE FRESH AIR ENTRY
DURING APPLIC & DRYING. IF YOU EXPERIENCE EYE WATERING, HDCH/DIZZ, INCR
FRESH A IR. WEAR RESPIRATORY PROTECTION (SUPDAT)
Ventilation: FOR REGULAR/CONTINUOUS USE-PROVIDE SUFFICIENT MECH (GEN) AND/OR
LOC EXHST VENT TO MAINTAIN EXPOSURE BELOW TLVS.
Other Protective Equipment: ANSI APPRVD EYE WASH & DELUGE SHOWER (FP N). WHERE
SPEC/UNUSUAL CNDTNS EXIST, SEEK EXPERT ASSISTANCE OF (SUPDAT)
Work Hygienic Practices: WASH HANDS BEFORE EATING/USING WASHROOM. AS WITH ALL
CHEMICALS, MINIMIZE PERSONAL CONTACT.
Supplemental Safety and Health: EXPLO HAZ: LOCATIONS DISTANT FROM MATL HNDLG
INDUSTRIAL HYGIENIST.
*
Physical/Chemical Properties
*
Vapor Pres: SEE INGS
Vapor Density: HVR/AIR
Spec Gravity: <1 (H*2O =1)
Evaporation Rate & Reference: SLOWER THAN ETHER
Solubility in Water: SLIGHT TO MODERATE
Appearance and Odor: TYPICAL SOLVENT PAINT.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: HEAT, SPARKS AND OPEN FLAME.
Materials To Avoid: AVOID CONTACT WITH STRONG OXIDIZING AGENTS AND HEAT.
Hazardous Decomposition Products: MAY FORM TOXIC MATERIALS, CARBON
DIOXIDE/CARBON MONOXIDE, VARIOUS HYDROCARBONS, NITROGEN CMPDS, ETC., WHEN
BURNED.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Company Name: PLASTI-KOTE CO INC
Label Required IND: Y
Status Code: C
Origination
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE. ACUTE: INHAL: EXCESS INHAL OF VAPORS CAN
CAUSE NASAL & RESPIRATORY IRRIT, DIZZINESS, WEAKNESS, FATIGUE, NAUS,
HDCH, POSSIBLE UNCON & EVEN ASPHY. EYE CONT: CAN CAUSE SEV IRRIT,
REDNESS, TEAR ING, BLURRED VISION. INGEST: CAN CAUSE GI IRRIT, NAUS, VOMIT,
DIARR. SKIN CONT: CAN CAUSE IRRIT FOR SOME PERSONS. CHRONIC: RPTS HAVE ASSOC
RPTD & PRLNGD OCCUP OVEREXPOSURE TO SOLVS W/PERM BRAIN & NERV SYS
DMG. SEV OVEREXPOSURE IN LAB ANIMALS HAS ALSO CAUSED LIVER ABNORMALITIES
&DMG TO KIDNEYS, LUNGS, & SPLEEN, HEART & ADRENALS. INTENTIONAL
MISUSE BY DELIBERATELY CONCENTRATING & INHALING CONTENTS M AY BE HARMFUL
OF FATAL.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED RESPIRATORY PROTECTION MAY BE
NECESSARY, IN THE ABSENSE OF LOCAL VENTILATION, TO CONTROL EMPLOYEE
EXPOSURE BELOW THE STATED PEL/TLV.
Ventilation:GOOD GENERAL WORKPLACE VENTILATION IS RECOMMENDED. USE
LOCAL FOR DUSTS, MIST, VAPORS OR HIGH TEMPERATURES.
Other Protective Equipment:NONE
Work Hygienic Practices:WASH THOROUGHLY AFTER USE.
Supplemental Safety and Health
PART A OF TWO PART KIT. SEE P/N IND "B", THIS NSN, FOR ADDITIONAL
INFORMATION. MORE INFORMATION ON FILE.
* Product Identification *
Kit Part:Y
Preparer's Name:DAVID HAAS
* Composition/Information on Ingredients *
Ingred Name:SILICONE COMPOUND
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE, SKIN AND RESPIRATORY TRACT
IRRITATION. HARNFUL IF INGESTED. BLURRED VISION/BURNING
SENSATION/TEARING. NAUSEA/HEADACHE.
* First Aid Measures *
MEDICAL ATTENTION IF IRRITATION PERSISTS, SKIN: REMOVE CONTAMINATED
CLOTHING. WASH AFFECTED AREAS WITH WATER. THEN WASH W/SOAP AND
WATER. GETMED AID.
* Fire Fighting Measures *
Lower Limits:NOT EST.
Upper Limits:NOT EST.
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER FOG
Fire Fighting Procedures:USE POSITIVE PRESSURE SCBA/FULL PROTECTIVE
EQUIPMENT. COOL CONTAINERS W/WATER (PREVENT PRESSURE BUILD-UP). IF
LOTS MATL INVOLVED EVACUATE/FIGHT AT SAFE DISTANCE
Unusual Fire/Explosion Hazard:TOXIC FUMES MAY BE EVOLVED UPON EXPOSURE
TO HEAT OR OPEN FLAMES. CLOSED CONTAINERS MAY VIOLENTLY RUPTURE
UNDER FIRE CONDITIONS.
* Accidental Release Measures *
Spill Release Procedures:SMALL SPILL: WIPE-UP/ABSORB WITH SUITABLE
MATERIAL. WASH AREA WITH SOAP & WATER. LARGE SPILL: WEAR PROTECTIVE
CLOTHING. DIKE AREA TO PREVENT SPREADING. SHOVEL/PUMP INTO DISPOSAL
CONTAINER. ABSORB RESI DUAL MATERIAL. WASH AREA WITH SOAP & WATER.
Neutralizing Agent:NONE
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINERS CLOSED AND AWAY FROM
HEAT OR OPEN FLAMES.
Other Precautions:NONE
* Physical/Chemical Properties *
Boiling Pt:B.P. Text:NOT EST.
Vapor Pres:NOT EST.
Vapor Density:NE
Spec Gravity:1.3
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR LIQUID
Percent Volatiles by Volume:<0.1
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS, BASES.
Stability Condition to Avoid:OPEN FLAME, CURRING AGENTS
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF SILICON, OTHER ORGANIC SUBSTANCES.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF AS A CHEMICAL WASTE IN ACCORDANCE
WITH CURRENT FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE DUST MASK.
Ventilation:NONE
Supplemental Safety and Health
* Product Identification *
Product ID:AMMONIA ABSORBER/FILTER
* Composition/Information on Ingredients *
Ingred Name:PHOSPHORIC ACID-D3
Ingred Name:CARBON, ACTIVATED CARBON, GRAPHITE
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:BROKEN PACKAGES MAY CAUSE SKIN/EYE
IRRITATION UPON CONTACT. MIXTURE CONTAINS MILD DILUTE ABSORBED
ACID.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
* First Aid Measures *
WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:WATER/DRY CHEMICALS
Fire Fighting Procedures:NONE
* Accidental Release Measures *
Spill Release Procedures:AVOID INHALATION OF DUST & SKIN CONTACT.
CONTAIN BROKEN CONTAINER & LOOSE PRODUCT IN POLYETHYLENE BAG. FLUSH
AREA W/WATER. NEUTRALIZE W/BICARBONATE OF SODA.
Neutralizing Agent:BICARBONATE OF SODA.
*Handling and Storage *
Other Precautions:AVOID INHALATION & SKIN CONTACT.
* Physical/Chemical Properties *
Solubility in Water:COMPLETE
Appearance and Odor:BLACK GRANULES W/NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
* Disposal Considerations *
Waste Disposal Methods:SPENT CONTAINER WHICH NOW CONTAINS AMMONIUM
PHOSPHATE MAY BE DISPOSED OF IN GARBAGE UNLESS PROHIBITED BY LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SHOULD NOT BE REQUIRED.
AIRBORNE LEVELS BEL RECOMMENDED EXPO LIMITS WHEN PROD USED.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:LAUNDER CONTAM CLOTHES/SHOES PRIOR TO REUSE.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:WATER
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMMONIUM THIOSULFATE
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM ACETATE
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMMONIUM BISULFITE (CERCLA)
Fraction by Wt: 4-8%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM TETRABORATE, DECAHYDRATE
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF SWALLOWED, CAUSES SKIN AND
EYE IRRITATION AND MAY CAUSE ALLERGIC SKIN REACTION.EYE:CAUSES
IRRIT.SKIN:CAUSES IRRIT.MAY CAUSE ALLERGIC SKIN
REACTION.ORAL:HAMRFUL IF SWALLOWED.MAY CAUSE IRRITOF
GASTROINTESTINAL TRACT.INHAL:VAPOR IRRIT.
Effects of Overexposure:EYE IRRIT, SKIN IRRIT, ALLERGIC SKIN REACTION.
IRRIT GASTROINTESTINAL TRACT.INHAL VAPOR IRRIT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
TARGET ORGANS:RESPIRATORY SYSTEM, EYES, SKIN.
* First Aid Measures *
First Aid:INHAL:MOVE TO FRESH AIR.OBTAIN MED ATTN IF REQUIRED.EYE:HOLD
ATTN.SKIN:IMMED FLUSH W/PLENTY OF WATER WHILE REMOVING CONTAM
CLOTH/SHOES.IN GEST:INDUCE VOMIT AS DIRECTED BY MED PERSONNEL.NEVER
GIVE ANYTHING BY MOUTH IF UNCONSC.OBTAIN MED CARE AND HOSPITAL
TREATMENT IMMED.
* Fire Fighting Measures *
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:NP
Lower Limits:NP
Upper Limits:NP
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CARBON DIOXIDE (CO2), OR
ALCOHOL FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING TO PREVENT CONTACT W/SKIN/EYES.
Unusual Fire/Explosion Hazard:NONE. EXCESSIVE HEAT MAY PRODUCE HAZ
DECOMPOSITION PRODUCTS.AMMONIA AND OXIDES OF SULFUR.
* Accidental Release Measures *
Spill Release Procedures:FLUSH TO SEWER W/LG AMOUNTS OF WATER (PH
4.5-5.5).OTHERWISE, ABSORB SPILL W/VERMICULITE OR OTHER SUITABLE
ABSORBENT AND PLACE IN IMPERVIOUS CONTAINER FOR DISPOSAL IN
APPROVED AND PERMITTED LANDFILL.CL EAN AREA THOROUGHLY TO REMOVE
RESIDUAL CONTAM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID CONTACT
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:NP
Decomp Temp:Decomp Text:NP
Spec Gravity:1.4
pH:4.5-5
Viscosity:NP
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT YELLOW LIQUID WITH PUNGENT ODOR (SULFUR
DIOXIDE)
Percent Volatiles by Volume:NP
Corrosion Rate:NP
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ACIDS AND BASES
Stability Condition to Avoid:PRODUCES AMMONIA IN THE PRESENCE OF BASES
OR HIGHT HEAT.
Hazardous Decomposition Products:EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.AMMONIA AND OXIDES OF SULFUR. SULFUR DIOXIDE
AND AMMONIA.
* Disposal Considerations *
Waste Disposal Methods:SOLN HAS PH THAT MAY CAUSE ADVERSE ENVIRO
EFFECGTS.ONCE NEUTRALIZED AND DILUTED THESE EFFECTS WILL BE
LESSENDED SUBSTANTIALLY.AMMONIA COMPONENTS ARE HARMFUL TO AQUATIC
LIFE.DISCHARGE/TREAT/DISPO MAY B E SUBJ TO CERTAIN GOVT REGS.NO
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT NEEDED IN NORMAL SERVICE.
Ventilation:USE GENERAL DILUTION VENTILATION.
Other Protective Equipment:PROTECTIVE CLOTHING,AS NEEDED.PROVIDE A
LOCAL EYE WASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:USE REASONABLE CARE IN HANDLING THIS
PRODUCT.WASH HANDS AFTER USE AND BEFORE EATING.
Supplemental Safety and Health
NONE
* Product Identification *
Preparer's Name:MARK GINDLING,DIR RSCH
CAGE:BURKE
CAGE:BURKE
CAGE:0MAHA
* Composition/Information on Ingredients *
Ingred Name:WATER
Other REC Limits: RECOMMENDED
Ingred Name:PROPYLENE GLYCOL PHENYL ETHER
Other REC Limits: RECOMMENDED
Ingred Name:TRIPROPYLENE GLYCOL METHYL ETHER
Fraction by Wt: <5%
Other REC Limits: RECOMMENDED
Ingred Name:SODIUM METASILICATE
Fraction by Wt: <3%
Other REC Limits: RECOMMENDED
Ingred Name:ISODECYLOXYPROPYLAMINODIPHROPIONIC ACID MONOSODIUM SALT
Fraction by Wt: <3%
Other REC Limits: RECOMMENDED
Ingred Name:ADDITIVES;INGRED 6+7=<5%
Fraction by Wt: <1%
Other REC Limits: RECOMMENDED
Ingred Name:COLOR AND PERFUME;INGRED 6+7=<5%
Other REC Limits: RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MFR REPORTS THE FOLLOWING-EYES:MAY
CAUSE SLIGHT IRRITATION.SKIN:NON-IRRITATING.INGEST:NON-
TOXIC.INHAL:NOT REPORTED.
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of Overexposure:EYES:IRRITATION.SKIN:DERMATITIS.
Medical Cond Aggravated by Exposure: SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH SOAP AND
WATER.SEE DOCTOR IF IRRITATION PERSISTS.EYES:FLUSH WITH COOL WATER
FRESH AIR.GIVE OXYGEN OR ARTIFICIAL RESPIRATION IF
NEEDED.INGEST:DO NOT INDUCE VOMITING.GET PROMPT QUALIFIED MEDICAL
ATTENTION.IF CONSCIOUS,GIVE 2 LARGE GLASSES OF WATER.
* Fire Fighting Measures *
Flash Point:
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:HMIS ADVISES TO USE A SELF-CONTAINED BREATHING
APPARATUS AND FULL PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:FIRE CONDITIONS MAY EVOLVE TOXIC FUMES.
* Accidental Release Measures *
Spill Release Procedures:MOP,PICK UP WITH A WET/DRY VAC OR SOAK UP WITH
NON-COMBUSTIBLE INERT ADSORBANT(EG.CLAY);PLACE COLLECTED MATERIAL
IN AN APPROPRIATE CONTAINER FOR DISPOSAL;CLEAN SPILL AREA AND ALLOW
TO DRY TO REMOVE SL IPPERINESS.
Neutralizing Agent:WEAK ACID(EG. VINEGAR).
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL,DRY,WELL-VENTILATED
PLACE.KEEP CONTAINER CLOSED WHEN NOT IN USE.KEEP AWAY FROM
HEAT,SPARKS,FLAMES AND INCOMPATIBLE MATERIALS.
Other Precautions:THIS PRODUCT MAY ETCH GLASS IF LEFT ON UNTIL DRYNESS.
* Physical/Chemical Properties *
HCC:B3
Evaporation Rate & Reference:1 WATER=1
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID,CLEAR;YELLOW;FLORAL ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CHLORINE BLEACH.
Stability Condition to Avoid: SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE,CARBON MONOXIDE,OXIDES
OF SILICON.
* Disposal Considerations *
Waste Disposal Methods:DILUTE WITH WATER;ADJUST PH BELOW 9;FLUSH TO
SEWER IN ACCORDANCE WITH FEDERAL,STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:PROTECTIVE CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:CHOLIC ACID
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE HARMFUL BY INHALATION,
INGESTION/SKIN ABSORPTION. IRRITATION. PROLONGED/REPEATED EXPOSURE
MAY CAUSE ALLERGIC REACTIONS IN CERTAIN INDIVIDUALS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, COUGHING, CHOKING, TIGHTNESS OF THE
CHEST.
* First Aid Measures *
First Aid:INGESTION: WASH OUT MOUTH W/WATER IF CONSCIOUS. SKIN: FLUSH
MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, CO2, DRY CHEMICAL POWDER/APPROPRIATE
FOAM.
Fire Fighting Procedures:WEAR SCBA & PROTECTIVE CLOTHING.
* Accidental Release Measures *
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. SWEEP UP, PLACE IN
A BAG & HOLD FOR WASTE DISPOSAL. AVOID RAISING DUST. VENTILATE AREA
& WASH SITE AFTER MATERIAL PICKUP IS COMPLETE.
*Handling and Storage *
Other Precautions:AVOID CONTACT & INHALATION.
* Physical/Chemical Properties *
Appearance and Odor:WHITE TO OFF-WHITE POWDER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:COMBUSTION: CO, CO2.
* Disposal Considerations *
Waste Disposal Methods:DISSOLVE/MIX W/A COMBUSTIBLE SOLVENT & BURN IN A
CHEMICAL INCINERATOR EQUIPPED W/AN AFTERBURNER & SCRUBBER,
IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR A PROPERLY FITTED VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA FOR USE W/PAINTS DURING
APPLICATION & UNTIL ALL VAPORS & SPRAY MISTS ARE EXHAUSTED.
CONFINED SPACES, USE A POSITIVE PRESSURE, SUPPLIED AIR RESPIRATOR
Ventilation:SUFFICIENT VENTILATION
Other Protective Equipment:COVERALLS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE
EATING/SMOKING.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:T R LOUER
* Composition/Information on Ingredients *
Ingred Name:2-PROPENOIC ACID 2-METHYL-METHYL ESTER, POLYMER
Ingred Name:ACETIC ACID, ETHYL ESTER, ETHYL ACETATE
Ingred Name:PROPYLENEGLYCOL MONOMETHYL ETHER ACETATE,
1-METHOXY-2-PROPANOL ACETATE
Fraction by Wt: 8%
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NOSE & THROAT IRRITATION.
REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE. SKIN: IRRITATION, BURNS, DERMATITIS.
EYES: IRRITATION, BURNING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:GI DISTRESS, IRRITATION, EYE WATERING,
HEADACHE, NAUSEA, DIZZINESS, LOSS OF COORDINATION, BURNS,
DISCOMFORT.
* First Aid Measures *
First Aid:INGESTION: CALL A PHYSICIAN IMMEDIATELY & HAVE THE NAMES OF
INGREDIENTS AVAILABLE. INHALATION: REMOVE TO FRESH AIR. SKIN: WASH
MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:CC
Lower Limits:0.9
Extinguishing Media:WATER SPRAY, FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT W/SCBA. WATER
FROM FOG NOZZLES MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:WHEN HEATED ABOVE THE FLASH POINT, EMITS
FLAMMABLE VAPORS WHICH, WHEN MIXED W/AIR, CAN BURN/EXPLODE. FINE
Other Precautions:DON'T SAND, FLAME CUT, BRAZE/WELD DRY COATING W/O
NIOSH/MSHA APPROVED RESPIRATOR/APPROPRIATE VENTILATION. OBSERVE
LABEL PRECAUTIONS. DON'T BREATHE VAPORS/MISTS. DON'T PERMIT ANYONE
W/O PROTECTION IN T HE PAINTING AREA.
* Physical/Chemical Properties *
Vapor Density:>1
VOC Grams/Liter:5.6
Evaporation Rate & Reference:(ETHER =1): <1
Solubility in Water:MISCIBLE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO, CO2, SMOKE.
* Disposal Considerations *
Waste Disposal Methods:DON'T ALLOW MATERIAL TO CONTAMINATE GROUND WATER
SYSTEMS. INCINERATE ABSORBED MATERIAL IAW/FEDERAL, STATE & LOCAL
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED SELF-CONTAINED BREATHING
APPARATUS WHERE INADEQUATE VENTILATION EXISTS. PERSONS WITH KNOWN
SENSITIZATIONS TO ISOCYANATES SHOULD NOT WORK WITH THIS MATERIAL.
Ventilation:LOCAL EXHAUST VENTILATION PREFERRED.
CLOTHING.
CONTACT;
Other Protective Equipment:A FACE SHIELD IS APPROPRIATE IF SPLASHING IS
LIKELY. HAVE EYE WASH AVAILABLE.
Work Hygienic Practices:NONE
Supplemental Safety and Health
NONE
* Product Identification *
Preparer's Name:ERNEST CARTER
* Composition/Information on Ingredients *
Ingred Name:METHYLENE BISPHENYL ISOCYANATE
Code:F
Ingred Name:AROMATIC ISOCYANATE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: EYE CONTACT WITH LIQUID PRODUCT
MAY CAUSE IRRITATION. SKIN: PROLONGED OR REPEATED CONTACT MAY CAUSE
IRRITATION.SKIN CONTACT MAY RESULTIN ALLERGIC SKIN REACTIONS OR
RESPIRATORY SENSITIZATION. I NHALATION:AT ROOM TEMPERATURE, VAPORS
ARE MINIMAL DUE TO LOW VAPOR PRESSURE OF MDI. OVEREXPOSURE TO
VAPORS GIVEN OFF BY HEATED PRODUCT OR MISTS GIVEN OFF BY SPRAYED
PRODUCT MAY CAUSE IRRITATION OF THE NOSE, THROAT AND RESPIRATORY
TRACT.SYMPTOMS OF OVEREXPOSURE MAY INCLUDE COUGHING, DIFFICULTY IN
BREATHING OR A TIGHT FEELING IN THE CHEST. INGESTION: HARMFUL IF
SWALLOWED.
Explanation of Carcinogenicity:THIS PRODUCT DOES NOT CONTAIN REGULATED
LEVELS OF NTP, IARC, ACGIH OR OSHA LISTED CARCINOGENS.
Effects of Overexposure:CHRONIC: LONG TERM OVEREXPOSURE TO VAPORS MAY
CAUSE REDUCED PULMONARY FUNCTION. RESPIRATORY IRRITATION, LUNG
DAMAGE AND TUMORS HAVE BEEN OBSERVED IN LABORATORY ANIMALS EXPOSED
TO DROPLETS OF MDI (6MG/ M3) FOR THEIR LIFETIME.
Medical Cond Aggravated by Exposure:PERSONS WITH EXISTING ASTHMATIC
CONDITIONS MAY EXPERIENCE ADDITIONAL DIFFICULTY IN BREATHING.
PERSONS WHO HAVE BEEN SENSITIZED TO ISOCYANATES MAY EXPERIENCE
SYMPTOMS AT VERY LOW EXPOSURE LEVELS.
* First Aid Measures *
First Aid:IF IN EYE: FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF WATER FOR
WITH SOAP AND WATER.LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
CALL A PHYSICIAN. IF VAPORS INHALED: REMOVE FROM EXPOSURE.PROVIDE
ARTIFICIAL RESPIRATION IF BREATHING HAS STOPPED. CALL A PHYSICIAN
IF SYMPTOMS PERSIST. IF INGESTED: IF PERSON CAN SWALLOW, GIVE ONE
GLASS OF WATER OR MILK. DO NOT INDUCE VOMITING, GET IMMEDIATE
MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:COC
Autoignition Temp:Autoignition Temp Text:
Lower Limits:
Upper Limits:
Extinguishing Media:USE WATER SPRAY, FOAM, DRY CHEMICAL OR CARBON
DIOXIDE.
Fire Fighting Procedures:PERSONS EXPOSED TO PRODUCTS OF COMBUSTION
SHOULD WEAR SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE
EQUIPMENT.
Unusual Fire/Explosion Hazard:
* Accidental Release Measures *
Spill Release Procedures:COVER WITH ABSORBENT MATERIAL. PLACE IN OPEN
TOPPED CONTAINER. REMOVE TO WELL VENTILATED AREA AND TREAT WITH
ADEQUATE AMMONIA.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:AVOID SKIN CONTACT WITH PRODUCT AT ALL
TMES. AVOID EXPOSURE TO MIST FROM SPRAYED PRODUCT OR VAPORS FROM
HEATED PRODUCT. STORAGE INFORMATION: CONSULT THE TECHNICAL DATA
SHEET FOR SPECIFIC STORAGE INSTR UCTIONS.
Other Precautions:
* Physical/Chemical Properties *
Boiling Pt:B.P. Text:
Melt/Freeze Pt:M.P/F.P Text:
Decomp Temp:Decomp Text:
Appearance and Odor:LIQUID AMBER NEUTRAL
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
WATER, ALCOHOLS, AMINES, STRONG ACIDS, STRONG BASES.
Stability Condition to Avoid:
Hazardous Decomposition Products:INCOMPLETE COMBUSTION CAN YIELD LOW
MOLECULAR WEIGHT HYDROCARBONS, CARBON MONOXIDE, NTROGEN COMPOUNDS
AND TRACES OF HYTROGEN CYANIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF WASTE MATERIAL ACCORDING TO STATE,
LOCAL OR PROVINCIAL REGULATIONS.
* Regulatory Information *
FOLLOWING TOXIC CHEMICAL(S') SUBJECT TO THE REPORTING REQUIREMENTS
Regulatory Information:
DOES NOT CONTAIN KNOWN LEVELS OF ANY CHEMICAL KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER OR CAUSE REPRODUCTIVE DAMAGE.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
NECESSARY.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENT TO KEEP AIRBORNE
CONCENTRATIONS BELOW THE PERMISSIBLE EXPOSURE LIMITS.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN EXPOSURE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MATL TO AVOID: ACID, PHOSPHORUS PENTOXIDE, POTASSIUM, POTASSIUM
HYDROXIDE, METHYL ALCOHOL, POTASSIUM TERT-BUTOXIDE, SODIUM, SODIUM
HYDROXIDE, SODIUM METHYLATE, SODIUM-POTASSIUM ALLOY,
TRIISOPROPYLPHOS PHINE, CALCIUM HYDROXIDE, FLUORINE, & ANY STRONG
OXIDIZERS.
* Product Identification *
* Composition/Information on Ingredients *
MG/KG.
Ingred Name:EFTS OF OVEREXP: TESTS W/LAB ANIMALS. CHRONIC INGEST MAY
CAUSE LIVER DMG. PRLNGD/RPTD SKIN CONTACT MAY CAUSE (ING 3)
Ingred Name:ING 2: DERMATITIS. PRLNGD/RPTD EXPOS MAY CAUSE ADVERSE
REPRO EFTS. MAY CAUSE FETAL EFTS. CHRONIC EXPOS HAS BEEN (ING 4)
Ingred Name:ING 3: ASSOC W/INCREASED INCIDENCE OF KIDNEY, LIVER,
RECTAL, BLADDER, COLON, BRAIN & LYMPH NODE CANCER. TOXICITY (ING 5)
Ingred Name:ING 4: MAY BE INCREASED BY EXPOS TO ALCOHOL, STEROIDS &
KETONES. TARGET ORGANS: KIDNEYS, HEART, CNS, LIVER, GI (ING 6)
Ingred Name:ING 5: SYSTEM, EXCRETORY SYSTEM.
Ingred Name:FIRST AID PROC: INHAL: GET MED AID IMMED. REMOVE FROM EXPOS
TO FRESH AIR IMMED. IF NOT BRTHG, GIVE ARTF RESP. IF (ING 8)
Ingred Name:ING 7: BRTHG IS DFCLT, GIVE OXYGEN. NOTES TO MD: CAUSES
CARD SENSIT TO ENDOGENOUS CATELCHOLAMINES WHICH MAY LEAD (ING 9)
Ingred Name:ING 8: TO CARD ARRHYTHMIAS. DO NOT USE ADRENERGIC AGENTS
SUCH AS EPINEPHRINE OR PSEUDOEPINEPHRINE. ANTIDOTE: NO (ING 8)
Ingred Name:ING 9: SPECIFIC ANTIDOTE EXISTS.
Ingred Name:EYE PROT: & FULL LENGTH FACESHIELD .
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYE: CONTACT W/LIQ OR VAP CAUSES SEV
BURNS & POSS IRREVERSIBLE EYE DMG. VAPS MAY CAUSE EYE IRRIT. SKIN:
MAY CAUSE IRRIT W/BURNING PAIN, ITCHING & REDNESS. INGEST: MAY
CAUSE CNS DEPRESS, KIDNEY DMG & L IVER DMG. MAY CAUSE GI IRRIT
W/NAUS, VOMIT & DIARR. MAY CAUSE CARD DISTURBS. ASPIR OF MATL INTO
LUNGS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:CHLOROFORM: IARC MONO, SUPP, VOL 7, PG
BE CARCIN.
Effects of Overexposure:HLTH HAZ: MAY CAUSE CHEM PNEUMIT WHICH MAY BE
FATAL. INHAL: INHAL OF HIGH CONCS MAY CAUSE CNS EFTS CHARACTERIZED
BY HDCH, DIZZ, UNCON & COMA. CAUSES RESP TRACT IRRIT. MAY CAUSE
LIVER & KIDNEY DMG. MAY CAUSE CARD SENSIT & POSS FAILURE. CHRONIC:
OVEREXP MAY CAUSE DELAYED KIDNEY INJURY. POSS CANCER HAZ BASED ON
(ING 2)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
OCCASNLY LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. DO NOT
ALLOW VICTIM TO RUB OR KEEP EYES CLOSED. SKIN: GET MED AID. RINSE
CLTHG & SHOES. INGEST: DO NOT INDUCE VOMIT. IF VICTIM IS CONSCIOUS
& ALERT, GIVE 2-4 CUPFULS OF MILK/WATER. POSS ASPIR HAZ. GET MED
AID IMMED. (ING 7)
* Fire Fighting Measures *
Extinguishing Media:USE WATER SPRAY, DRY CHEMICAL OR FOAM. USE
EXTINGUISHING MEDIA MOST APPROPRIATE FOR THE SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . SUBSTANCE IS NONFLAMMABLE.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTIVE EQUIPMENT AS
INDICATED. ABSORB SPILL WITH INERT MATERIAL (EG, DRY SAND OR
EARTH), THEN PLACE INTO A CHEMICAL WASTE CONTAINER. AVOID RUNOFF
INTO STORM SEWERS AND DITCHES WHICH LEAD TO WATERWAYS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:WASH THOROUGHLY AFTER HNDLG. REMOVE
CONTAM CLTHG & WASH BEFORE REUSE. USE W/ADEQ VENT. DO NOT GET ON
SKIN OR IN EYES. AVOID INGEST & INHAL.
Other Precautions:DO NOT STORE IN DIRECT SUNLIGHT. STORE IN A COOL,
DRY, WELL-VENTILATED AREA AWAY FROM INCOMPATIBLE SUBSTANCES. KEEP
AWAY FROM ACIDS. DO NOT STORE NEAR ALKALINE SUBSTANCES.
* Physical/Chemical Properties *
Spec Gravity:1.5 (H*2O=1)
Appearance and Odor:CLEAR, COLORLESS LIQUID; SWEET, FRUITY ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACETONE, ALKALIS, ALUMINUM, DISILANE, LITHIUM, MAGNESIUM, DINITROGEN
DIOXIDE, NITROGEN TETROXIDE, PERCHLORIC (SUPDAT)
Stability Condition to Avoid:STABLE AT ROOM TEMP IN CLOSED CNTNRS UNDER
NORMAL STORAGE & HNDLG CNDTNS. AVOID HIGH TEMPS, INCOMPATIBLE
MATLS, LIGHT.
Hazardous Decomposition Products:HYDROGEN CHLORIDE, CARBON DIOXIDE,
CHLORINE, PHOSGENE GAS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
| 1 | eyes_protection_mandatory |
Control Measures
*
Kit Part: Y
Proprietary Ind: Y
*
Preparer Co. when other than Responsible Party Co.
*
*
Contractor Summary
*
*
Item Description Information
*
Item Manager: GSA
Item Name: RESIN,EPOXY
Specification Number: NONE
Type/Grade/Class: NONE
Unit of Issue: KT
UI Container Qty: S
Type of Container: CARTRIDGE
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: YES
Effects of Exposure: EYE:MAY CAUSE SLIGHT TRANSIENT EYE IRRIT. CORNEAL INJURY
IS UNLIKELY. SKIN:PROLONGED EXPOSURE NOT LIKELY TO CAUSE SIGNIFICANT SKIN
IRRITATION. REPEATRED EXPOSURE MAY CAUSE SKIN IRRITATION. HAS CAUSED
ALLERGIC SKIN REACTION IN HUMANS.
Explanation Of Carcinogenicity: DIGLYCIDYL ETHER OF BISPHENOL A IS NOT BELIEVED
TO BE A CANCER HAZARD TO HUMANS. (MFR CHECKED OSHA!?)
Signs And Symptions Of Overexposure: EYE:MAY CAUSE SLIGHT TRANSIENT (TEMPORY)
EYE IRRITATION. CORNEAL INJURY UNLIKELY. SKIN:PROLONGED EXPOSURE NOT LIKELY
TO CAUSE SIGNIFICANT IRRITATION. REPEATED EXPOSURE MAY CAUSE IRRITATION. HAS
CAUSED SKIN REACTION IN HUMANS.
Medical Cond Aggravated By Exposure: NONE ESTABLISHED
First Aid: EYE:IRRIGATE IMMEDIATELY W/WATER FOR 5 MINUTES. SKIN:WASH OFF IN
FLOWING WATER OR SHOWER. INGEST:NO ADVERSE EFFECTS ANTICIPATED BY THIS ROUTE
OF EXPOSURE INCIDENTAL TO PROPER INDUSTRIAL HANDLING. INHA LED:REMOVE TO
FRESH AIR IF EFFECTS OCCUR. CONSULT A PHYSICIAN. NO SPECIFIC ANTIDOTE.
SUPPORTIVE CARE. TREATMENT BASED ON JUDGMENT OF THE PHYSICIAN IN RESPONSE TO
REACTIONS OF THE PATIENT.
*
Handling and Disposal
*
Spill Release Procedures: SOAK UP W/ABSORBENT MATERIAL & COLLECT IN
SUITABLE CONTAINERS. KEEP SPARK PRODUCING EQUIPMENT AWAY. LARGE
SPILLS:EVACUATE UPWIND OF SPILLS & CONTAIN WITH DIKE. RESIDUAL RESIN MAY
BE REMOVED USING STEA M OR HOT SOAPY WATER. DO NOT USE SOLVENTS.
Neutralizing Agent: MFR GAVE NO INFORMATION ON MSDS.
Waste Disposal Methods: BURN IN ADEQUATE INCINERATOR OR BURY IN AN APPROVED
LANDFILL IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS.
Handling And Storage Precautions: PRACTICE GOOD CAUTION & PERSONAL
CLEANLINESS TO AVOID SKIN AND EYE CONTACT. AVOID BREATHING VAPORS OF HEATED
MATERIAL.
Other Precautions: PRACTICE GOOD CAUTION & PERSONAL CLEANLINESS TO AVOID
SKIN AND EYE CONTACT. AVOID BREATHING VAPORS OF HEATED MATERIAL.
*
Fire and Explosion Hazard Information
*
Extinguishing Media: FOAM, CARBON DIOXIED, DRY CHEMICAL
Fire Fighting Procedures: WEAR POSITIVE PRESSURE SELF CONTAINED BREATHING
APPARATUS.
Unusual Fire/Explosion Hazard: NONE KNOWN.
*
*
Respiratory Protection: NO RESPIRATORY PROTECTION SHOULD BE NEEDED.
Ventilation: GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT FOR MOST CONDITIONS.
Other Protective Equipment: NONE ESTABLISHED
Work Hygienic Practices: MFR:?. :USE GOOD CHEMICAL HYGIENE PRACTICES. AVOID
CONTACT IF AT ALL POSSIBLE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health: KEY1:N1
*
Physical/Chemical Properties
*
HCC: N1
NRC/State LIC No: NONE
Solubility in Water: NONE
Appearance and Odor: WATER-WHITE TO YELLOW LIQUID TO SEMI-SOLID, FAINT EPOXY
ODOR
Corrosion Rate: UNKNOWNN
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: EXCESS HEATING OVER LONG PERIODS OF TIME DEGRADES
THE RESIN.
Materials To Avoid: BASE, ACID, AMINES, AND OXIDIZING MATERIALS
Hazardous Decomposition Products: BY-PRODUCTS OF THERMAL DECOMPOSITION ARE
PHENOLICS, CARBON MONOXIDE, WATER. THEY ARE POTENTIALLY HAZARDOUS. CAUTION.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: MASSES OF MORE THAN 1 POUND OF PRODUCT PLUS
AN ALIPHATIC AMINE WILL CAUSE POLYMERIZATION W/CONSIDERABLE HEAT BUILD UP.
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
Transportation Information
*
Net Unit Weight: UNKNOWN
Multiple KIT Number: 0
Kit Part IND: Y
Review IND: Y
Unit Of Issue: KT
Container QTY: S
Type Of Container: CARTRIDGE
Additional Data: U/I ISSUE IS A KIT CONTAINING BOTH THIS ITEM AND
DIETHYLENETRIAMINE. QUANTITY (2 FL OZ) IS LIMITED Q UANTITY. ITEM IS SUCH
THAT THE PARTS CANNOT BE SHIPPED SEPARATELY.
*
Detail DOT Information
*
DOT PSN Code: FAD
DOT Proper Shipping Name: DIETHYLENETRIAMINE
Hazard Class: 8
DOT Packaging Group: II
Label: CORROSIVE
Special Provision: B2,T8
Max Qty Pass: 1 L
Vessel Stow Req: A
*
Detail IMO Information
*
IMO PSN Code: FRB
IMO Proper Shipping Name: DIETHYLENETRIAMINE
UN Hazard Class: 8
IMO Packaging Group: II
Subsidiary Risk Label: -
*
Detail IATA Information
*
IATA PSN Code: JIR
IATA Proper Shipping Name: DIETHYLENETRIAMINE
IATA UN Class: 8
IATA Label: CORROSIVE
UN Packing Group: II
Max Quant Pass: 1L
*
Detail AFI Information
*
AFI PSN Code: JIR
AFI Proper Shipping Name: DIETHYLENETRIAMINE
AFI Hazard Class: 8
AFI Packing Group: II
Special Provisions: P5
*
HAZCOM Label
*
Company Name: DOW CORNING CORP
Label Required IND: Y
Status Code: C
MFG Label NO: NONE
Origination Code: F
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Severe
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: **TARGET ORGANS:SKIN, EYES, RESPIRATORY SYSTEM**
CORROSIVE TO BODY TISSUES. PRODUCES SEVERE BURNS ON CONTACT (LIQUID) AND
SEVERE IRRITATION (VAPORS). MAY BE ABSORBED THROUGH THE SKIN IN HARMFUL AMOU
NTS. HOLD BULK STORAGE UNDER NITROGEN BLANKET. THIS PRODUCT SHOULD NOT COME
IN CONTACT W/COPPER-BEARING ALLOYS. IN CASE OF SPILL: LARGE:DIKE UP &
PUMP INTO APPROPRIATE CONTAINERS. SMALL:DILUTE W/WATER & RECOVER OR USE
NON-COMBUSTIBLE ABSORBENT MATERIAL/SAND & SHOVEL INTO SUITABLE
CONTAINERS.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NOT REQUIRED
Work Hygienic Practices:GOOD PERSONAL HYGIENE (CLEANLINESS)
Supplemental Safety and Health
NONE
* Product Identification *
Product ID:ZIP FIXER OR TRAY FIXER
* Composition/Information on Ingredients *
Ingred Name:ACETIC ACID (SARA III)
Fraction by Wt: 3%
Ingred Name:SODIUM METABISULFITE
Fraction by Wt: 2%
OSHA PEL:5 MG/M3
Ingred Name:WATER
Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: BALANCE
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED SKIN CONTACT MAY PRODUCE
RASH FROM ACID BURN.
Explanation of Carcinogenicity: SPECIFIED BY MANUFACTURER.
Effects of Overexposure:SKIN RASH FROM ACID BURN.
Medical Cond Aggravated by Exposure: SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:WASH AFFECTED AREA WITH COLD WATER. IF SWALLOWED, DO NOT
INDUCE VOMITING; CALL A PHYSICIAN.
* Fire Fighting Measures *
Flash Point:
Extinguishing Media: SPECIFIED BY MANUFACTURER.
Fire Fighting Procedures: SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard: SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:FLUSH WITH WATER.
Neutralizing Agent: SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID TEMPERATURE EXTREMES. STORE
Other Precautions: SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:N1
Vapor Density:<1
Evaporation Rate & Reference:<1
Solubility in Water:COMPLETE
Appearance and Odor:PALE YELLOW SOLUTION; VINEGAR ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID STRONG ACIDS.
Stability Condition to Avoid: SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:STRONG ACIDS MAY PRODUCE HYDROGEN
SULFIDE FUMES
* Disposal Considerations *
Waste Disposal Methods:FLUSH TO SEWER IF LOCAL REGULATIONS PERMIT.
| 1 | eyes_protection_mandatory |
Control Measures
*
Product ID: TZ FLOOR PREP
Cage: 0NWE2
*
Preparer Co. when other than Responsible Party Co.
*
Cage: 0NWE2
*
Contractor Summary
*
Cage: 0NWE2
*
Ingredients
*
% Wt: <1
-----------------------------
% Wt: <4
-----------------------------
% Wt: <1
-----------------------------
% Wt: <1
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES: MILDLY IRRITATING. INHALATION: MILD IRRITATION TO
UPPER RESPIRATORY TRACT.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: IRRITATION
Medical Cond Aggravated By Exposure: SENSITIVITY TO SULFUR COMPOUNDS.
& WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION: DON'T INDUCE
VOMITING. DILUTE CONTENTS OF STOMACH W/3-4 GLASSES OF MILK/WATER. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
*
Handling and Disposal
*
Spill Release Procedures: VENTILATE AREA. ABSORB W/ABSORBENT MATERIAL &
PLACE IN PROPER WASTE DISPOSAL CONTAINER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL
REGULATIONS.
Handling And Storage Precautions: KEEP CONTAINERS CLOSED. KEEP FROM FREEZING.
*
Fire and Explosion Hazard Information
*
Flash Point Text: DOES NOT FLASH
Extinguishing Media: CO2, DRY CHEMICAL/WATER
Fire Fighting Procedures: NONE
Unusual Fire/Explosion Hazard: NONE
*
*
Respiratory Protection: NONE REQUIRED
Ventilation: ADEQUATE VENTILATION
Other Protective Equipment: NOT GENERALLY REQUIRED.
Work Hygienic Practices: WASH THOROUGHLY W/WATER AFTER USING THIS PRODUCT.
EXPERT ASSISTANCE OF AN INDUSTRIAL HYGENIST/QUALIFIED PROFESSIONAL.
*
Physical/Chemical Properties
*
Vapor Density: 1
Spec Gravity: 1
Solubility in Water: COMPLETE
Appearance and Odor: SLIGHTLY AMBER CLEAR LIQUID W/LOW ODOR
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: FREEZING
Hazardous Decomposition Products: SULFUR OXIDES, AMMONIA, NITROGEN OXIDES
Hazardous Polymerization Indicator: NO
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Product ID: TZ FLOOR PREP
Cage: 0NWE2
Company Name: H-I-S PAINT MFG
Label Required IND: Y
Status Code: A
Origination Code: G
Hazard And Precautions: EYES: MILDLY IRRITATING. INHALATION: MILD IRRITATION TO
UPPER RESPIRATORY TRACT.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED DUST RESPIRATOR.
Ventilation:LOCAL EXHAUST: ADEQUATE TO REDUCE EXPOSURE TO BELOW LIMITS.
MECHANICAL (GENERAL): DUST COLLECTOR. OTHER: NO APPLICABLE
INFORMATION FOUND.
.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER . SHOP COAT OR APRON TO PROTECT THE CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY WITH SOAP AND WATER AFTER USE.
FOLLOW ESTABLISHED SAFETY POLICIES.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:MULTIWAX
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: COUGHING AND/OR SNEEZING.
Effects of Overexposure:COUGHING AND/OR SNEEZING IF DUST IS GENERATED
DURING USE. POSSIBLE EYE OR SKIN IRRITANT.
Medical Cond Aggravated by Exposure:UPPER RESPIRATORY AILMENTS.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. SKIN/EYES: FLUSH WITH WATER
VOMITING AND SEEK IMMEDIATE MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:COC
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY POWDER OR WATER FOG.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . TOXIC VAPORS MAY BE RELEASED UNDER FIRE CONDITION.
Unusual Fire/Explosion Hazard:AVOID SPREADING BURNING LIQUID WITH
WATER.
* Accidental Release Measures *
Spill Release Procedures:USE SUITABLE MEANS TO MINIMIZE DUST (I.E.,
VACUUM). DRY SWEEEPING IS NOT RECOMMENDED.
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM SOURCES OF IGNITION.
Other Precautions:NO APPLICABLE INFORMATION FOUND.
* Physical/Chemical Properties *
Solubility in Water:INSOLUBLE
Appearance and Odor:LIGHT YELLOW COLOR, WITH A TYPICAL WAXY ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NO APPLICABLE INFORMATION FOUND.
Stability Condition to Avoid:KEEP AWAY FROM HEAT AND SOURCES OF
IGNITION.
Hazardous Decomposition Products:NO APPLICABLE INFORMATION FOUND.
* Toxicological Information*
Toxicological Information:PERMISSIBLE EXPOSURE LEVEL: HYDROGEN CHLORIDE
GAS-5 PPM BY VOLUME MAX. EFTS OF CHRONIC OVEREXP: CAN CAUSE REMOVAL
OF ENAMEL FROM TEETH. NO OTHER INFO AVAIL. EFTS OF ACUTE OVEREXP:
CAN BE FATAL IF SWAL LOWED. FUMES CAN CAUSE SEV IRRIT OF EYES,
NOSE, THROAT, & LUNGS. MAY CAUSE BRONCH, & PNEUM IF INHALED
DIRECTLY. CORR TO EYES & SKIN BY DIRECT CONT. EXPOS LIMITS: 5 PPM
AS HYDROGEN CHLORIDE(TLV). IRRIT ANCY OF PROD: STRONG. SENSITIZ TO
PROD: NO. CARCIN: NO. TERATOGENICITY: NO. REPRO TOX: NO.
MUTAGENICITY: NO SYNERGISTIC PRODS: ALKALIS, NITRITES, AND
NITRATES.
* Disposal Considerations *
Waste Disposal Methods:ACCORDING TO FEDERAL, STATE AND LOCAL
REGULATIONS.
* MSDS Transport Information *
* Regulatory Information *
SARA Title III Information:THIS PRODUCT CONTAINS FOLLOWING TOXIC
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF PERSONAL EXPOSURE CAN'T BE CONTROLLED BELOW
TLV BY VENTILATION, USE A NIOSH/MSHA APPROVED PROPERLY FITTED
ORGANIC VAPOR/PARTICULATE RESPIRATOR. WHEN SANDING/ABRADING FILM,
USE A NIOSH/MSHA APPROVED DUST/MIST RESPIRATOR.
Ventilation:LOCAL EXHAUST: PREFERABLE. GENERAL EXHAUST: ACCEPTABLE IF
THE EXPOSURE IS KEPT < APPLICABLE EXPOSURE LIMITS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS AFTER USING.
Supplemental Safety and Health
PH: 8.5-9.8.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ETHYLENE GLYCOL, GLYCOL
Fraction by Wt: <5%
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICON DIOXIDE, CRYSTALLINE QUARTZ, SAND (ANIMAL CARC,
Fraction by Wt: 6%
OSHA PEL:0.1 MG/CUM RESP DUST
ACGIH TLV:0.1 MG/CUM RESP DUST
Ingred Name:CLAY (KAOLIN), ALUMINUM SILICATE
OSHA PEL:5 MG/CUM
Ingred Name:TITANIUM DIOXIDE, TIO2 (SUSPECTED ANIMAL CARCINOGEN, IARC
Fraction by Wt: 9%
Ingred Name:WATER
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF EYES, SKIN & UPPER
RESPIRATORY SYSTEM. CRYSTALLINE SILICA-LONG TERM EXPOSURE TO HIGH
LEVELS OF SILICA DUST MAY CAUSE LUNG DAMAGE (SILICOSIS). PROLONGED
OVEREXPOSURE TO SOLVENTS MAY CAUSEADVERSE EFFECTS TO THE LIVER,
URINARY SYSTEMS.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, HEADACHE, NAUSEA, DIZZINESS,
REDNESS, ITCHING, BURNING SENSATION.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. KEEP WARM
& QUIET. SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/LARGE AMOUNTS OF
* Fire Fighting Measures *
Extinguishing Media:CO2, DRY CHEMICAL, ALCOHOL FOAM
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIPMENT & SCBA. WATER
SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE. USE WATER TO COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO THE
BUILD UP PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
* Accidental Release Measures *
Spill Release Procedures:REMOVE SOURCES OF IGNITION. VENTILATE & REMOVE
WITH INERT ABSORBENT.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
TRANSFER ONLY TO APPROVED CONTAINERS W/COMPLETE & APPROPRIATE
LABELING. DON'T TAKE INTERNALLY.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. USE ONLY W/ADEQUATE
VENTILATION. AVOID BREATHING VAPOR & SPRAY MIST. AVOID CONTACT
W/SKIN & EYES.
* Physical/Chemical Properties *
Vapor Density:>1
Spec Gravity:1.1-1.3
pH:(SUPP)
Evaporation Rate & Reference:SLOWER THAN ETHER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:EXTREME HEAT & OTHER IGNITION SOURCES.
Hazardous Decomposition Products:BY FIRE: CO2, CO
* Disposal Considerations *
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DON'T
INCINERATE CLOSED CONTAINER. DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE AMINE ORGANIC CARTRIDGE VAPOR RESPIRATOR, IF
NEEDED.
Ventilation:GERNERAL MECHANICAL AND LOCAL EXHAUST I/A/W ACGIH
RECOMMENDATIONS.
Other Protective Equipment:NO INFORMATION GIVEN BY MFR ON MSDS.
Work Hygienic Practices:MFR: ? HMIS:USE STRICT CHEMICAL HYGIENE
PRACTICE. AVOID UNNECESSARY EXPOSURE. WASH THOROUGHLY BEFORE EATING
OR DRINKING.
Supplemental Safety and Health
MSDS RECEIVED FROM NAVY (FOCAL POINT N). CAGE CODE AND NSN IDENTIFIED
BY THEM.
* Product Identification *
Kit Part:Y
Preparer's Name:M. MUNSELL
* Composition/Information on Ingredients *
Ingred Name:TRIETHYLENE TETRAMINE
Ingred Name:CALCIUM CARBONATE (MARBLE) (LIMESTONE)
Ingred Name:ALUMINUM (SARA III)
Ingred Name:SILICA GEL (FUMED SILICA)
OSHA PEL:6 MG/M3
Ingred Name:ALUMINUM HYDROXIDE
Ingred Name:NONYLPHENOL
Ingred Name:POLYAMIDE RESIN
Ingred Name:1,3 BENZENEDIMETHANAMINE, POLY W/2,2'-(1-METHYLETHYLIDENE)
BIS (4,1-PHENYLENEOXYMETHTLENE) BIS (OXIRANE) & OTHERS
Ingred Name:DIETHYLENETRIAMINE
OSHA PEL:1 PPM
Ingred Name:4,4'-ISOPROPYLIDENEDIPHENOL (SARA III)
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN:IRRITATION. INHALATION:HEATED
PRODUCT MAY PRODUCT INHALABLE VAPORS. EYE:CORROSIVE. CAUSES BURNS.
SKIN:POSSIBLE SENSITIZATION IN SUSCEPTIBLE INDIVIDUALS. IRRITATION.
Explanation of Carcinogenicity:NONE OF THE INGREDIENTS OF THIS PRODUCT
ARE BY IARC, NTP OR OSHA AS A CARCINOGEN.
Effects of Overexposure:CAUSES EYE BURNS & SKIN IRRITATION. MAY CAUSE
ALLERGIC SKIN & RESPIRATORY REACTIONS.
Medical Cond Aggravated by Exposure:SKIN/EYE CONDITIONS.
* First Aid Measures *
First Aid:CONSULT A PHYSICIAN IF THERE IS QUESTION AS TO SEVERETY OF
SKIN:WASH WITH SOAP & WATER. REMOVE CONTAMINATED CLOTHING & LAUNDER
BEFORE RE-USE. INGESTION:IF CONSCIOUS, GIVE PLENTY OF WATER TO
DRINK. DO NOT INDUCE VOMITING. CALL PHYSICIAN. INHALATION: REMOVE
TO FRESH AIR. GIVE OXYGEN/ARTIFICIAL RESPIRATION, IF NEEDED. CALL
PHYSICIAN.
* Fire Fighting Measures *
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:DECOMPOSITION & COMBUSTION PRODUCTS MAY
BE TOXIC.
* Accidental Release Measures *
Spill Release Procedures:REMOVE SPILLAGE BY ABSORBING IN ABSORBENT
MATERIAL.
Neutralizing Agent:GET IMMEDIATE MEDICAL ATTENTION
*Handling and Storage *
Handling and Storage Precautions:DANGER! CORROSIVE - CAUSES EYE BURNS
AND SKIN IRRITATION. HARMFUL IF ABSORBED THROUGH SKIN. AVOID
CONTACT WITH SKIN & CLOTHING. WASH AFTER HANDLING.
Other Precautions:MAY CAUSE ALLERGIC SKIN & RESPIRATORY REACTION. DO
NOT GET IN EYES. AVOID PROLONGED/REPEATED SKIN CONTACT. KEEP
CONTAINER CLOSED. USE WITH ADEQUATE VENTILATION. NUISANCE DUST MAY
BE GENERATED WHEN SA NDING OR SAWING CURED MATERIAL.
* Physical/Chemical Properties *
HCC:N1
NRC/State Lic Num:NONE
Vapor Pres:<0.1 MM
Solubility in Water:SLIGHT
Appearance and Odor:DARK GRAY PASTE, WITH AMMONIACAL ODOR.
Percent Volatiles by Volume:<1
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZIERS, ACIDS & BASES.
Stability Condition to Avoid:EXCESSIVE HEAT FOR PROLONGED PERIODS OF
TIME.
Hazardous Decomposition Products:COMBUSTION MAY FORM TOXIC MATERIALS,
SUCH AS CARBON DIOXIDE AND CARBON MONOXIDE
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:CONSULT QUALIFIED LOCAL OR CORPORATE PERSONNEL
FOR METHOD THAT WILL COMPLY WITH LOCAL, STATE & FEDERAL HEALTH &
ENVIRONMENTAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED IF GOOD VENTILATION IS MAINTAINED.
WEAR NIOSH/MSHA APPROVED RESPIRATOR SUITABLE FOR CONCENTRATIONS &
TYPE OF AIR CONTAMINANTS ENCOUNTERED.
Ventilation:NORMAL ROOM VENTILATION.
Other Protective Equipment:SAFETY SHOWER, EYEWASH FACILITY & PROTECTIVE
CLOTHING.
Work Hygienic Practices:WASH EXPOS AREA THORO W/SOAP & WATER AFTER
HNDLG THIS MATL & SPECIALLY BEFORE EATING, SMOKING, DRINKING/USING
(SUPDAT)
Supplemental Safety and Health
FIRST AID PROC:WEEKS/EVEN MONTHS OF FREQUENT & PROLONGED CONTACT.
HYGIENE PRACT:TOILET FACILITIES.
* Product Identification *
Kit Part:Y
Preparer's Name:RAJESH S. PATEL
POLYMERS
* Composition/Information on Ingredients *
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE:INHAL:VAPOR OR FUMES CAN
POSSIBLY BE HARMFUL IF INHALED. EYE CONTACT:SUBSTANTIALLY
IRRITATING. SKIN:MODERATELY IRRITATING. INGEST:SUBSTANCE CAN BE
POSSIBLY HARMFUL IF SWALLOWED. CHRONIC:PROLONGE D OR REPEATED
EXPOSURE CAN CAUSE ALLERGIC REACTION.
CARCIN; OSHA(SUPDAT)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:ALLERGY, ECZEMA, EYE & RESPIRATORY
DISEASES CONDITIONS.
* First Aid Measures *
First Aid:INHAL:MOVE SUBJECT TO FRESH AIR. EYE:FLUSH W/LG AMTS OF WATER
WATER. REMOVE & WASH CLTHG BEFORE REUSE. INGEST:IF SWALLOWED DILUTE
BY G IVING 2 GLASSES OF WATER TO DRINK. SEE MD. NEVER GIVE ANYTHING
BY MOUTH TO AN UNCON PERS. NOTE TO MD:ALLERGIC DERM/RESP RESPONSE
IN SUSCEPTIBLE INDIVIDUALS MAY BE DELAYED. IT MAY APPEAR AFTER
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:CO*2, DRY CHEMICAL, WATER SPRAY, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:DECOMPOSITION & COMBUSTION PRODUCTS MAY
BE TOXIC.
* Accidental Release Measures *
Spill Release Procedures:DIKE & ABSORB SPILL ON INERT MATERIAL (SAND,
EARTH, ETC). TRANSFER TO CONTAINERS FOR DISPOSAL. REMOVE
CONTAMINATED CLOTHING & WASH SKIN AREAS W/SOAP & WATER. WASH
CLOTHING BEFORE REUSE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
AVOID ALL SKIN CONTACT. MAY CAUSE ALLERGIC REACTION.
Other Precautions:PLEASE READ MSDS BEFORE HANDLING THE PRODUCT.
* Physical/Chemical Properties *
Vapor Density:>1
Spec Gravity:1 (H*2O=1)
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:MODERATE
Appearance and Odor:AMBER COLOR LIQUID; MILD AMMONIACAL ODOR.
Percent Volatiles by Volume:1 (WT)
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:ELEVATED TEMPERATURES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE LIQUID; LANDFILL CONTAMINATED DIKING
MATERIAL I/A/W LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF AIRBORNE DUST LEVELS ARE HIGH, A NIOSH
APPROVED DUST MASK IS RECOMMENDED TO AVOID INHALATION.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
APPLICATORS & OTHER HANDLERS MUST WEAR: LONG-SLEEVED SHIRT & LONG
PANTS, SHOES PLUS SOCKS. FOLLOW MFR'S INSTRUCTIONS FOR
CLEANING/MAINTAINING (SUPDAT)
Work Hygienic Practices:WASH HANDS AFTER HANDLING.
Supplemental Safety and Health
OTHER PROTECTIVE EQUIPMENT: PERSONAL PROTECTIVE EQUIPMENT (PPE). IF NO
SUCH INSTRUCTIONS FOR WASHABLES, USE DETERGENT & HOT WATER. KEEP &
WASH PPE SEPARATELY FROM OTHER LAUNDRY.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:NUISANCE DUST
OSHA PEL:5 MG/M3 (MFR)
Ingred Name:ANILINE, 3,4-DIMETHYL-2,6-DINITRO-N-(1- ETHYLPROPYL)-;
(PENDIMETHALIN)
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: POSSIBLE NAUSEA, VOMITING AND
DIARRHEA. MAY IRRITATE EYES, NOSE, THROAT, AND SKIN. CAUSES EYE
IRRITATION WITH CORNEAL INVOLVEMENT CLEARING IN 7 DAYS IN TEST
CHRONIC: NONE LISTED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
* First Aid Measures *
PHYSICIAN IF IRRITATION PERSISTS. INGESTION: CALL PHYSICIAN OR
POISON CONTROL CENTER. DRINK 1-2 GLASSES OF WATER & INDUCE VOMITING
BY TOUCHI NG BACK OF THROAT W/FINGER. IF PERSON IS UNCONSCIOUS, DO
NOT GIVE ANYTHING BY MOUTH & DO NOT INDUCE VOMITING. SKIN: WASH
W/PLENTY OF SOAP & WATER. GET MEDICAL ATTENTION IF IRRITATION
PERSISTS. INHALAT ION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRATION, PREFERABLY MOUTH TO MOUTH. GET MEDICAL
ATTENTION.
* Fire Fighting Measures *
Extinguishing Media:DRY CHEMICAL, WATER FOG, CO*2, FOAM. CONTAIN RUNOFF
AS ACTIVE INGREDIENT.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP SPILLS. USE GOOD HOUSEKEEPING
PRACTICES. AVOID CONTACT WITH SKIN, EYES, OR CLOTHING.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:READ LABEL FOR STORAGE & DISP
INSTRUCTIONS. AVOID CONTAMINATION W/OXIDIZING AGENTS/STRONG ALKALI.
AVOID BAG BREAKAGE. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:AVOID INHAL OR CONACT WITH SKIN, EYES, OR CLOTHING.
KEEP OUT OF LAKES, STREAMS, OR PONDS. DO NOT CONTAMINATE FEED OR
FOODSTUFF.
* Physical/Chemical Properties *
Appearance and Odor:GRANULAR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS OR STRONG ALKALI.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:IN FIRE, THERMAL DECOMP OF UREA &
METHYLENE UREAS WILL GENERATE AMMONIA. OXIDES OF NITROGEN & CARBON
ARE ALSO POSSIBLE.
* Disposal Considerations *
Waste Disposal Methods:SEE LABEL. DISPOSE OF SMALL WASTE QTYS ACCORDING
TO LABEL DIRECTIONS. FOR LARGE QTYS OF WASTE, CONSULT LOCAL WASTE
OFFICIALS. DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS .
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED RESPIRATOR WHEN AIRBORNE LEVELS
MAY EXCEED PEL.
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER . AS
NECESSARY TO AVOID PROLONGED CONTACT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
* Product Identification *
Product ID:SPRAY MARK OVER, CH FREE, TAN
* Composition/Information on Ingredients *
Ingred Name:HYDROCARBON PROPELLANT (PROPANE/ISOBUTANE)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:LIGROINE; (ALIPHATIC PETROLEUM DISTILLATES)
Fraction by Wt: 3-7%
Fraction by Wt: <1%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:VAPOR EXPOSURE MAY CAUSE SHORTNESS OF
BREATH, DIZZINESS, LIGHTHEADEDNESS, CENTRAL NERVOUS SYSTEM EFFECTS
OR LIVER AND KIDNEY EFFECTS. VAPOR MAY IRRITATE EYES. PROLONGED
SKIN CONTACT CAN CAUSE IRRITATI ON, DEFATTING OF SKIN AND POSSIBLY
DERMATITIS. CHRONIC: TOLUENE APPEARS ON THE NAVY LIST OF (EFTS OF
OVEREX)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: OCCUPATIONAL CHEMICAL REPRODUCTIVE
HAZARDS. SEEK CONSULTATION FROM APPROPRIATE HEALTH PROFESSIONALS
CONCERNING LATEST HAZARD LIST INFO AND SAFE HANDLING AND EXPOSURE
INFO .
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. WASH SKIN
WITH SOAP AND WATER. INHALATION: REMOVE TO FRESH AIR. IF DISCOMFORT
PERSISTS, S EEK MEDICAL ATTENTION. INGESTION: DO NOT INDUCE
VOMITING. CALL MD IMMEDIATELY.
* Fire Fighting Measures *
Lower Limits:1.0%
Extinguishing Media:WATER FOG, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:EXPOSURE TO HEAT OR TEMPERATURE ABOVE
PROPELLANT.
* Accidental Release Measures *
Spill Release Procedures:ISOLATE FROM SOURCES OF IGNITION. VENTILATE TO
REMOVE PROPELLANT VAPORS. CONTAIN SPILL USING SUITABLE ABSORBENT.
CONTAINERIZE IN AN APPROVED DOT CONTAINER FOR PROPER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
CAUSE CONTAINER TO BURST, RELEASING THE HIGHLY FLAMMABLE
PROPELLANT.
Other Precautions:PROPELLANT VAPORS ARE HEAVIER THAN AIR. VENTILATE TO
PREVENT CONCENTRATION FROM REACHING FLAMMABLE LEVELS.
* Physical/Chemical Properties *
Vapor Density:HVR/AIR
Spec Gravity:SUPDAT
Evaporation Rate & Reference:SLOWER (ETHER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TAN AEROSOL WITH AROMATIC ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZIERS, STRONG ALKALIES, STRONG MINERAL ACIDS.
OR IGNITION.
Hazardous Decomposition Products:CARBON MONOXIDE, TRACES OF PHOSGENE
FROM BURNING.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR LEAD, IF
Ventilation:USE ENOUGH VENTILATION (GENERAL/LOCAL) TO KEEP THE FUMES
FROM THE WORKERS BREATHING ZONE & BELOW PEL. HEPA FILTERS REQD.
Other Protective Equipment:AS REQUIRED TO AVOID CONTACT.
Work Hygienic Practices:WASH THOROUGHLY BEFORE EATING OR SMOKING.
LAUNDER CONTAMINATIED CLOTHING BEFORE REUSE. FOLLOW GOOD HYGIENIC
PRACTICES.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:LEAD (SARA III)
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TIN
Other REC Limits:NONE SPECIFIED
OSHA PEL:2 MG/M3
Ingred Name:ANTIMONY (SARA III)
Fraction by Wt: <2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.5 MG/M3
Ingred Name:ROSIN ACID
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MOLTEN SOLDER ALLOYS DO NOT PRODUCE
AIRBORNE OR INGESTED LEAD MAY PRODUCE SYMPTOMS OF ANEMIA,
INSOMINIA, WEAKNESS, CONSTIPATION, NAUSEA & ABDOMINAL PAIN.
PROLONGED EXPOSURE MAY RESULT IN KIDNEY & NERVOUS SYSTEM
INVOLVEMENT. PREGNANT WOMEN SHOULD AVOID LEAD.
Explanation of Carcinogenicity:NOT LISTED BY NTP, IARC OR OSHA AS A
CARCINOGEN.
Effects of Overexposure:LOSS OF APPETITE, METALLIC TASTE IN THE MOUTH,
ANXIETY, CONSTIPATION, NAUSEA, PALLOR, EXCESSIVE TIREDNESS,
WEAKNESS, INSOMNIA, HEADACHE, NERVOUS IRRITABILITY, MUSCLE AND
JOINT SORENESS, TREMORS, DIZZI NESS, AND ABDOMINAL PAIN. WHEN
HEATED, FUMES MAY CAUSE EYE, SKIN & RESPIRATORY TRACT IRRITATION.
SOLDER CAN CAUSE BURNS.
Medical Cond Aggravated by Exposure:DISEASES OF THE BLOOD-FORMING,
NERVOUS, URINARY, RESPIRATORY AND REPRODUCTIVE SYSTEMS. EXPOSURE TO
LEAD MAY RESULT IN INJURY TO A DEVELOPING FETUS.
* First Aid Measures *
First Aid:IF A PERSON BREATHES IN A LARGE AMOUNT OF ROSIN FUME, REMOVE
FROM EXPOSURE. IF BREATHING IS DIFFICULT, ADMINISTER OXYGEN AND
CALL A PHYSICIAN. IF LEAD HAS BEEN INGESTED, IMMEDIATELY CALL A
PHYSICIAN.NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
FOR EYE BURNS, FLUSH IMMEDIATELY WITH COOL WATER AND OBTAIN MEDICAL
AID. FOR SKIN BURNS, COOL WITH WATER AND OBTAIN MEDICAL AID.
* Fire Fighting Measures *
Flash Point:NON FLAMMABLE
Autoignition Temp:Autoignition Temp Text:NONE
Extinguishing Media:USE DRY SAND OR DRY CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:SOLID AT ROOM TEMPERATURE. IF IN MOLTEN STATE,
ALLOW TO COOL AND SOLIDIFY AND THEN SCRAPE UP. VACUUM UP SMALL
PARTICLES. NEVER USE ANY METHOD WHICH WILL GENERATE DUST.
*Handling and Storage *
Handling and Storage Precautions:NO SPECIAL REQUIREMENTS FOR STORAGE.
READ ALL CONTAINER LABELING. FOOD AND DRINK SHOULD NOT BE CONSUMED
OR TOBACCO PRODUCTS USED WHERE SOLDER IS USED.
Other Precautions:AVOID CONTACT WITH FUMES AND DUST.
* Physical/Chemical Properties *
HCC:T4
Vapor Pres:0
Solubility in Water:NEGLIGIBLE
Appearance and Odor:SILVER GRAY SOLID
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:THE SMOKE FROM A SOLDERING OPERATION
MAY INCLUDE CARBON MONOXIDE, ABIETIC ACID, ALIPHATIC ALDEHYDES &
DITERPENE ACIDS.
* Disposal Considerations *
Waste Disposal Methods:RECLAIM ALLOY OR DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE & LOCAL LAWS AND REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT EXPECTED TO BE NECESSARY. USE NIOSH/MSHA
APPROVED ORGANIC VAPOR CARTRIDGE AND DUST/MIST PRE-FILTER
AND NIOSH-RESPIRATOR SELECTION WHEN EXPOSED ABOVE PEL/TLV.
Ventilation:GENERAL ROOM VENTILATION IS NORMALLY ADEQUATE. LOCAL
EXHAUST MAY BE REQUIRED IF WORK AREA IS NOT VENTED.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. AVOID UNNECESSARY CONTACT.
Supplemental Safety and Health
THIS IS PART B OF A TWO PART KIT. SEE P/N IND A, THIS NSN OR
* Product Identification *
Kit Part:Y
Preparer's Name:AS
* Composition/Information on Ingredients *
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT MAY BE IRRITATING AND MAY
CAUSE LIVER AND/OR KIDNEY DAMAGE. IT ALSO MAY SENSITIZE ALLERGIC
REACTIONS.
Explanation of Carcinogenicity:MFR CLAIMS NO COMPOUND IN THIS PRODUCT
IS LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYE:IRRITATION,BURNING. SKIN:IRRITATION. MAY
CAUSE SKIN RASH IN SENSITIZED INDIVIDUALS.INHALED:RESPIRATORY
IRRITATION. INGESTED:NAUSEA,VOMITING,G/I PAIN & DISTRESS, AND
POSSIBLE LIVER AND/OR KIDNEY DAMAGE.
Medical Cond Aggravated by Exposure:SENSITIZED PEOPLE ARE AT INCREASED
RISK WHEN USING THIS PRODUCT.
* First Aid Measures *
CLOTHING. WASH WITH SOAP & WATER. LAUNDER CLOTHING BEFORE REUSE.
INHALED:REMOVE TO FRESH AIR. RESTORE BREATHING. GET MEDICAL CARE.
INGESTED:DO NOT INDUCE VOMITING. GIVE TWO GLASSES OF WATER AND GET
IMMEDIATE MEDICAL ATTENTION. (GIVE NOTHING BY MOUTH IF UNCONSCIOUS)
- IF ANY IRRITATION IS SEVERE OR PERSISTS, GET MEDICAL CARE.
* Fire Fighting Measures *
Flash Point:NON-FLAMMABLE
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:WIPE/SOAK UP WITH CLOTH OR PAPER TOWEL OR
INERT ABSORBENT. PUT IN DISPOSAL CONTAINER. REMOVE RESIDUE WITH
SOLVENT.
Neutralizing Agent:USE 1,1,1-TRICHLOROETHANE AS SOLVENT
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT
CONTAINERS FROM PHYSICAL DAMAGE.
Other Precautions:NONE
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:NOT DESCRIBED ON MSDS BY MFR
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
SULFUR DIOXIDE, HYDROGEN SULFIDE, POSSIBLE FORMALDEHYDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE I/A/W FEDERAL,STATE,LOCAL REGULATIONS.
MFR STATES THAT PRODUCT MAY BE DISPOSED AS ORDINARY REFUSE.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF WORKPLACE EXPOSURE LIMIT(S) OF PROD/ANY
COMPONENT IS EXCEEDED, A NIOSH/MSHA APPRVD AIR SUPPLIED RESP IS
ADVISED IN ABSENCE OF PROPER ENVIRONMENTAL CONTROL. OSHA REGS ALSO
PERMIT OTHER NIOSH/MSHA AP PRVD RESPIRATORS UNDER SPECIFIED (ING 3)
Ventilation:MATERIAL MUST BE HANDLED OR TRANSFERRED IN AN APPROVED FUME
HOOD OR WITH ADEQUATE VENTILATION.
Other Protective Equipment:EYE WASH AND SAFETY EQUIPMENT SHOULD BE
READILY AVAILABLE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. DO NOT TAKE
INTERNALLY.
Supplemental Safety and Health
FIRST AID PROC:WATER. GET IMMED MED ATTN. OTHER PREC:STATIC DISCHARGE,
SMOKING, HEATERS/ELECTRIC MOTORS AT LOCATIONS DISTANT FROM MATERIAL
HANDLING POINT. NEVER USE WELING/CUTTING TORCH ON OR NEAR DRU M,
EVEN EMPTY, BECAUSE PROD, OR RESIDUE, CAN IGNITE EXPLOSIVELY. EMPTY
CNTNRS ARE HAZ DUE TO RETAINED RESIDUE.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:FORMALDEHYDE (SARA III)
Ingred Name:METHANOL
Ingred Name:RESP PROT: CONDITIONS. ENGINEERING AND/OR ADMINISTRATIVE
CONTROLS SHOULD BE IMPLEMENTED TO REDUCE EXPOSURE.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:FORMALDEHYDE HAS THE POTENTIAL TO
CAUSE CANCER IN HUMANS. REPEATED AND PROLONGED EXPOSURE INCREASES
THE RISK. IN HUMANS, FORMALDEHYDE EXPOSURE HAS BEEN ASSOCIATED WITH
CANCERS OF THE LUNGS, NASOPHARYN X AND OROPHARYNX, AND NASAL
PASSAGES. HARMFUL IF INHALED, SWALLOWED, OR ABSORBED THROUGH THE
SKIN. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:FORMALDEHYDE: GROUP 2A (IARC),
ANTICIPATED TO BE A CARCINOGEN (NTP), OSHA REGULATED.
Effects of Overexposure:HLTH HAZ: EYE CONTACT MAY CAUSE PERMANENT
DAMAGE. MAY CAUSE BLINDNESS IF SWALLOWED. SEVERE SKIN IRRITANT AND
A SENSITIZER. DEATHS FROM ACCIDENTAL EXPOSURE TO HIGH
CONCENTRATIONS OF FORMALDEHYDE HAS BE EN REPORTED.
Medical Cond Aggravated by Exposure:RESPIRATORY CONDITIONS.
* First Aid Measures *
First Aid:GET IMMED MED ASSISTANCE FOR ALL CASES OF OVEREXP. SKIN:WASH
THORO W/SOAP & WATER. REMOVE CONTAM CLTHG AT ONCE (LAUNDER BEFORE
REUSE); DISCARD CONTAM SHOES. EYES:IMMED FLUSH THORO W/WATER FOR AT
HAS STOPPED. INGEST:IF CONSCIOUS, DILUTE, INACTIVATE, OR ABSORB THE
INGESTED FORMALDEHYDE BY GIVING MILK, ACTIVATED CHARCOAL, OR (SUPP
DATA)
* Fire Fighting Measures *
Flash Point Method:CC
Lower Limits:7.0 %
Extinguishing Media:DRY CHEMICAL, "ALCOHOL FOAM", CARBON DIOXIDE. WATER
SPRAY TO COOL EXPOSED CONTAINERS AND DISPERSE VAPORS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MODERATE FIRE & EXPLO HAZ. FORMALDEHYDE
REACTS W/NITROGEN DIOXIDE, NITROMETHANE, PERCHLORIC ACID AND
ANILINE, OR PEROXYFORMIC ACID TO YIELD EXPLOSIVE COMPOUNDS.
* Accidental Release Measures *
Spill Release Procedures:DIKE SPILL, TAKE UP WITH ABSORBENT AND
CONTAINERIZE FOR PROPER DISPOSAL. EM SCIENCE SPILL-X NEUTRALIZER
AND ABSORBENT AGENTS ARE RECOMMENDED FOR CHEMICAL SPILLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CNTNR TIGHTLY CLOSED. PROT
AGAINST PHYSICAL DMG. DO NOT BREATHE VAPOR/SOLN MIST. DO NOT GET IN
Other Precautions:SEPARATE FROM OXIDIZING & ALKALINE MATERIAL. INDOOR
STORAGE SHOULD HAVE FLOORS PITCHED TOWARD TRAPPED DRAIN OR STORE IN
CURBED RETENTION AREA. VAPORS ARE HEAVIER THAN AIR AND MAY TRAVEL
AND BE IGNITED BY PILOT LIGHTS, SPARKS, (SUPP DATA)
* Physical/Chemical Properties *
HCC:F5
Vapor Pres:1.3
Evaporation Rate & Reference:SIMILAR TO WATER
Solubility in Water:SOLUBLE
Appearance and Odor:COLORLESS LIQUID, PUNGENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACIDS, OXIDIZERS. ISOCYANATES, STRONG ALKALIES, PHENOL, ANHYDRIDES,
OXIDES AND INORGANIC ACIDS.
Stability Condition to Avoid:HEAT, SPARK, OPEN FLAME. CONTACT WITH HCL
MAY CAUSE FORMATION OF THE POTENT CARCINOGEN, BISCHLOROMETHYL
ETHER.
Hazardous Decomposition Products:OXIDES OF CARBON, FORMIC ACID.
* Disposal Considerations *
Waste Disposal Methods:TO BE PERFORMED IN COMPLIANCE WITH ALL CURRENT
LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Other Protective Equipment:WEAR IMPERVIOUS CLOTHING OR BOOTS.
Work Hygienic Practices:N/K
Supplemental Safety and Health
EXPLANATION OF CARCINOGENICITY:ACGIH A2=SUSPECTED HUMAN
* Product Identification *
Preparer's Name:RICHARD H WALTER
* Composition/Information on Ingredients *
Ingred Name:FORMALDEHYDE (SARA III)
Fraction by Wt: 3.7%
Other REC Limits:N/K
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
Fraction by Wt: 0.8%
Other REC Limits:N/K
* Hazards Identification *
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:MAY CAUSE EYE DAMAGE.PRODUCT IS
CORROSIVE AND IS A SENSITIZER.MIXTURE NOT TESTED AS A WHOLE.THE
MIXTURE IS ASSUMED TO PRESENT THE SAME HEALTH HAZARDS AS DO THE
COMPONENTS.
Explanation of Carcinogenicity:FORMALDEHYDE:LIMITED EVID FOR CARCIN IN
Effects of Overexposure:EYES:IRRITATING.MAY CAUSE REDDENING,TEARING AND
EYE DAMAGE.SKIN:IRRITATING TO SKIN AND MUCOUS
MEMBRANES.INGESTION/INHALATION:MAY CAUSE COLLAPSE AND
UNCONSCIOUSNESS.
Medical Cond Aggravated by Exposure:N/K
* First Aid Measures *
FINGER.INHALATION:GIVE FRESH AIR.GIVE ARTIFICIAL RESPIRATION IF
BREATHING HAS STOPPED.GET MEDI CAL ATTENTION.
* Fire Fighting Measures *
Extinguishing Media:ALCOHOL FOAM,WATER FOG,CARBON DIOXIDE,DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN
* Accidental Release Measures *
Spill Release Procedures:NEUTRALIZE WITH 2% AMMONIA AND ABSORB ON
PAPER,VERMICULITE,ETC.GENERALLY SMALL QUANTITIES MAY BE DISPOSED OF
IN A SANITARY LANDFILL.
Neutralizing Agent:2% AMMONIA SOLUTION.
*Handling and Storage *
Handling and Storage Precautions:CONTAINERS ARE POTENTIALLY HAZARDOUS
WHEN EMPTY.DO NOT REUSE.
Other Precautions:N/K
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Spec Gravity:N/K
pH:4.0
Solubility in Water:UNLIMITED
Appearance and Odor:CLEAR COLORLESS LIQUID WITH MILD ODOR.
Percent Volatiles by Volume:4.5
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CONTACT WITH STRONG ALKALINES OR STRONG MINERAL ACIDS.
Hazardous Decomposition Products:NONE KNOWN
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .GENERALLY,LABORATORY SCALE
QUANTITIES MAY BE PLACED IN CONTAINER WITH SUFFICIENT ABSORBANT
MATERIAL AND DISPOSED OF IN A SANITARY LANDFILL.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH COMPLIANT RESPIRATORS OR
SELF-CONTAINED BREATHING APPARATUS ABOVE EXPOSURE LIMITS. FOLLOW
Ventilation:ADEQUATE TO PRVNT ACCUMULATION OF VAPS. USE MECH MEANS IF
NEC TO MAINTAIN LEVELS BELOW EXPOS LIMITS. IF WORKING IN A CONFINED
SPACE, FOLLOW APPLIC OSHA REGS.
Other Protective Equipment:EYE WASH AND DELUGE SHOWER MEETING ANSI
GLASSES. USE A SPLASH APRON AND BOOTS IF SPLASHING OCCURS.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:METHANOL
< Wt:4.
Ingred Name:ISOPROPYL ALCOHOL
Ingred Name:POLYTETRAFLUOROETHYLENE
Ingred Name:WATER
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION, EYES AND INGESTION:
NOT APPLICABLE. SKIN: MINOR DERMATITIS IF SENSITIVE. CHRONIC: NOT
APPLICABLE. EMERGENCY OVERVIEW: APPEARANCE & ODOR: TRANSLUCENT
WHITE GELATINOUS. DANGER:E XTREMELY FLAMMABLE. HARMFUL/FATAL IF
SWALLOWED.CONTENTS UNDER PRESSURE.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NOT APPLICABLE.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE ARTIFICIAL RESPIRATION
IF NECESSARY. EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST
SOAP A ND WATER. INGESTION: NOTE: LOW ORAL TOXICITY. CALL MD
IMMEDIATELY .
* Fire Fighting Measures *
Flash Point Method:COC
Flash Point:NONE
Extinguishing Media:NONE REQUIRED.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . REMOVE CONTAINERS FROM FIRE AREA IF POSSIBLE.
Unusual Fire/Explosion Hazard:NFPA: HEALTH 1, FLAMMABILITY: 0,
REACTIVITY: 0. HMIS: HEALTH: 1, FLAMMABILITY: 0, REACTIVITY: 0 PPE:
B.
* Accidental Release Measures *
Spill Release Procedures:AREA SHOULD BE VENTILATED. ABSORBENT SHOULD BE
USED TO PICK UP EXCESS MATERIAL. ALL USED AND UNUSED PRODUCT SHOULD
BE DISPOSED OF IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY AREA.
* Physical/Chemical Properties *
pH:7.8
Solubility in Water:SOLUBLE
Appearance and Odor:TRANSLUCENT WHITE, GELATINOUS LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Hazardous Decomposition Products:NONE.
* Toxicological Information*
Toxicological Information:LONG-TERM TOXICOLOGICAL STUDIES HAVE NOT BEEN
CONDUCTED FOR THIS PRODUCT. SEE SECTION 3 OF THIS MSDS FOR ACUTE
SYMPTOMS OF OVEREXPOSURE AND CARCINOGENICITY INFORMATION.
* Ecological Information *
Ecological:ECOTOXICITY: NO DATA AVAILABLE. ENVIRONMENTAL FATE: NO DATA
AVAILABLE FOR BIODEGRADATION.
* Disposal Considerations *
Waste Disposal Methods:THIS MATERIAL IF DISCARDED MAY BE HAZARDOUS
WASTE UNDER US EPA RCRA REGULATIONS. ALL DISPOSAL ACTIVITIES MUST
COMPLY WITH FEDERAL, STATE AND LOCAL REGULATIONS. CONTACT YOUR
LOCAL OR STATE ENVIRONMENTA L AGENCY FOR SPECIFIC RULES. DO NOT
DUMP INTO SEWERS, ON THE GROUND OR INTO ANY BODY OF WATER.
* MSDS Transport Information *
Transport Information:SHIPPING NAME: NOT REGULATED. HAZARD CLASS, UN
NUMBER, PACKING GROUP, LABEL, PLACECARD, AND SPECIAL PROVISIONS:
NOT APPLICABLE.
* Regulatory Information *
HAZARDOUS SUBSTANCES: NO.
Federal Regulatory Information:TSCA: ALL COMPONENTS ARE EITHER LISTED
UNDER TSCA OR ARE EXEMPT.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:THE USE OF A NIOSH APPROVED MASK FOR TOXIC DUSTS
IS REQUIRED IF CURED PRODUCT IS TO BE DRY SANDED, ABRADED, ETC.
Ventilation:LOCAL EXHAUST REQUIRED WHEN SANDING CURED PRODUCT.
MECHANICAL (GENERAL) VENTILATION IS RECOMMENDED.
Other Protective Equipment:AS NEEDED TO PROTECT SKIN AND CLOTHING.
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:ALKYLAMINES
Other REC Limits:NONE SPECIFIED
Ingred Name:COUPLING AGENT
Fraction by Wt: 2%
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Health Hazards Acute and Chronic:MAY CAUSE SKIN IRRITATION AND POSSIBLE
ALLERGIC REACTIONS. PROLONGED AND REPEATED CONTACT MAY CAUSE
SENSITIZATION WHICH WILL RESULT IN ALLERGIC REACTIONS.
* First Aid Measures *
First Aid:FLUSH SKIN AND EYE CONTACT WITH PLENTY OF WATER. WASH SKIN
THOROUGHLY WITH SOAP AND WATER, RUBBING ALCOHOL OR HAND CLEANER. DO
NOT USE SOLVENTS. REMOVE SOILED CLOTHING AND WASH BEFORE REUSE. IF
IRRITA TION PERSISTS OR INCREASES, SEE PHYSICIAN.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY OR FOG, FOAM, CO2, DRY CHEMICAL
EXTINGUISHERS.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS WHEN
FIGHTING FIRES IN CONFINED LOCATIONS.
Unusual Fire/Explosion Hazard:DENSE SMOKE AND TOXIC GASES MAY BE
LIBERATED.
* Accidental Release Measures *
GLASSES. SCRAPE UP AND TRANSFER TO METAL CONTAINER. WIPE UP
REMAINING RESIDUE WITH SOLVENTS, OBSERVING SOLVENT FLAMMABILITY
CAUTIONS, OR USE DETERGENT.
*Handling and Storage *
Handling and Storage Precautions:KEEP PRODUCT COOL IN ACCORDANCE WITH
LABEL INSTRUCTIONS.
Other Precautions:FOLLOW RECOMMENDED CURING SCHEDULE.
* (HAZARDOUS POLYMERIZATION CONDITIONS TO AVOID CONT'D) TO BE BONDED.
FAILURE TO OBSERVE CAUTIONS MAY RESULT IN EXCESSIVE HEAT BUILD-UP
WITH THE RELEASE OF TOXIC GASES.
* Physical/Chemical Properties *
Appearance and Odor:TRANSPARENT RED LIQUID WITH AMMONICAL ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG LEWIS OR MINERAL ACIDS.
Hazardous Decomposition Products:CO, NOX, ALDEHYDES, ACIDS AND
UNDETERMINED ORGANICS.
Conditions to Avoid Polymerization:MIXING RESIN & CURING AGENT IN
UNLESS CURING SURFACES *
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF AS HAZARDOUS WASTE ACCORDING TO DOT
HAZARDOUS CLASS. IF NOT REGULATED BY DOT, DISPOSE OF AS ORM-E.
DISPOSAL METHOD CAN BE LAND BURIAL OR CHEMICAL INCINERATION AS
REGULATED BY ALL GOVERNMENT AL AGENCIES.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT ORDINARILY REQUIRED.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING AND BOOTS.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR SMOKING. LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
DO NOT SMOKE IN ANY CHEMICAL HANDLING OR STORAGE AREA. FOOD OR
BEVERAGES SHOULD NOT BE CONSUMED ANYWHERE THIS PRODUCT IS HANDLED
OR STORED
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:ASBESTOS (FRIABLE) (SARA III)
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:0.2 - 2 FIBERS/CC
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ALLYL GLYCIDYL ETHER (AGE)(VP = 1.7 MMHG)
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:EYES: CAN CAUSE IRRITATION, REDNESS,
TEARING, BLURRED VISION. SKIN: CONTACT CAN CAUSE MODERATE
IRRITATION. PROLONGED OR REPEATED CONTACT CAN CAUSE SENSITIZATION.
INHALATION: NOT LIKELY DUE TO THE LOW VOLATILITY OF THE MATERIAL.
Effects of Overexposure:REDNESS, SMARTING, TEARING OF THE EYE. DRYNESS
& CRACKING OF THE SKIN.
Medical Cond Aggravated by Exposure:NONE STATED BY THE MANUFACTURER.
* First Aid Measures *
First Aid:INHALATION: MOVE PERSON TO FRESH AIR. TREAT SYMPTOMATICALLY.
GET MEDICAL HELP. EYES: FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF
AFFECTED S KIN AREAS WITH SOAP AND WATER. IF POLYMER PERSISTS ON
SKIN, WASH W/ISOPROPYL ALCOHOL. IF IRRIT PERSISTS, GET MED AID.
INGESTION: DON'T INDUCE VOMITING. KEEP PERSON WARM/QUIET, GET MED
AID.
* Fire Fighting Measures *
Extinguishing Media:CARBON DIOXIDE, FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:WATER MAY BE UNSUITABLE AS AN
EXTINGUISHING MEDIA, BUT HELPFUL IN KEEPING ADJACENT CONTAINERS
COOL.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. PERSONS NOT
WEARING PROTECTIVE EQUIPMENT SHOULD BE EXCLUDED FROM AREA OF SPILL
UNTIL CLEAN-UP HAS BEEN COMPLETED. STOP SPILL AT SOURCE AND DIKE
AREA. SHOVEL INTO SAL VAGE OR WASTE CONTAINERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL DRY AREA. CONTAINERS OF
THIS MATERIAL MAY BE HAZARDOUS WHEN EMPTIED.
Other Precautions:SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUE
(VAPOR, LIQUID AND/OR SOLID) ALL HAZARD PRECAUTIONS GIVEN IN THIS
MSDS MUST BE OBSERVED.
* Physical/Chemical Properties *
Vapor Density:NA
Spec Gravity:1.1
Appearance and Odor:HEAVY GREY PASTE.
Percent Volatiles by Volume:0.0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AMINES, ANHYDRIDES, EPOXY CURING AGENTS.
Stability Condition to Avoid:PREMATURE MIXING WITH CURING AGENTS
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE AND
VARIOUS HYDROCARBONS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL SHOULD BE DONE IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT NORMALLY REQUIRED. IF VAPOR CONCENTRATION IS
HIGH, USE A NIOSH APPROVED ORGANIC VAPOR RESPIRATOR.
Ventilation:MECHANICAL EXHAUST MAY BE NEEDED IN CONFINED SPACES.
Other Protective Equipment:EYEWASH STATION & SAFETY SHOWER, RUBBER
APRONS.
Work Hygienic Practices:MFR:? HMIS:USE GOOD INDUSTRIAL HYGIENE
PRACTICES. MINIMIZE CONTACT & WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
CLEAN CONTAMINATED EQUIPMENT W/SOAP & WATER. DO NOT DISCHARGE WASH
WATER INTO LAKES, STREAMS, PONDS OR PUBLIC WATERS.
* Product Identification *
Product ID:GLIDSAFE PREPSOLVE
* Composition/Information on Ingredients *
Ingred Name:D-LIMONENE
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-PROLONGED &/OR REPEATED SKIN
CONTACT CAN CAUSE IRRITATION. SKIN SENSITIZATION:MAY CONTAIN TRACES
OF MATERIAL THAT IS ALLERGENIC TO SENSITIVE INDIVIDUALS. EXCESSIVE
INHALATION OF VAPORS CAN CAUSE RESPIRATORY IRRITATION, SORE
THROAT, COUGHING, SHORTNESS OF BREATH, NAUSEA & DIZZINESS.
CHRONIC-NOT DETERMINED.
Explanation of Carcinogenicity:MANUFACTURER GAVE NO INFORMATION ABOUT
CARCINOGENICITY. HMIS FOUND NO LISTING & DOES NOT EXPECT IT TO BE
CARCINOGENIC.
Effects of Overexposure:SKIN:IRRITATION, POSSIBLE SENSITIZATION.
INHALATION:RESPIRATORY IRRITATION, SORE THROAT, COUGHING, SHORTNESS
OF BREATH, NAUSEA & DIZZINESS.
Medical Cond Aggravated by Exposure:NONE KNOWN
* First Aid Measures *
First Aid:IF IRRITATION PERSISTS OR IS SEVERE, GET MEDICAL ATTENTION.
CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE. INHALED:REMOVE FROM
EXPOSURE. A ID OR RESTORE BREATHING AS NEEDED. INGESTED:DRINK LOTS
OF WATER TO DILUTE SUSBSTANCE. GET IMMEDIATE MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:DRY CHEMICAL, FOAM OR CARBON DIOXIDE. IF WATER MUST
BE USED, USE AS A SPRAY.
Fire Fighting Procedures:MFR GAVE NO INFORMATION ON MSDS.
Unusual Fire/Explosion Hazard:FLAMMABLE LIQUID. AVOID HEAT, SPARKS AND
OPEN FLAMES.
* Accidental Release Measures *
Spill Release Procedures:USE PERSONAL PROTECTIVE EQUIPMENT SPECIFIED ON
MSDS. SMALL SPILLS MAY BE ADSORBED BY DIRT, SAND OR OTHER SUITABLE
ADSORBENT. LARGE SPILL: MAY BE DIKED WITH EARTH AND PUMPED TO
CLOSED CONTAINER FOR REC OVERY OR DISPOSAL.
Neutralizing Agent:MFR GAVE NO INFORMATION ON MSDS.
*Handling and Storage *
Handling and Storage Precautions:AVOID HEAT, SPARKS & OPEN FLAMES.
AVOID WARM STORAGE. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE.
STORE AWAY FROM SSTRONG ACIDS & BASES.
WHEN HANDLING. AVOID PROLONGED EXPOSURE TO AIR.
* Physical/Chemical Properties *
HCC:F4
NRC/State Lic Num:NONE
Vapor Pres:1.0 MM
Vapor Density:4.7
Solubility in Water:<0.1%
Appearance and Odor:CLEAR, NEARLY COLORLESS LIQUID WITH A CITRUS ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & BASES. MATERIAL THAT REACT W/UNSATURATED HYDROCARBONS.
Stability Condition to Avoid:PROLONGED OR EXCESSIVE HEAT MAY CAUSE
DECOMPOSITION.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE, ACRID
FUMES.
* Disposal Considerations *
Waste Disposal Methods:PRODUCT IS CONSIDERED A HAZARDOUS WASTE BY U.S.
INCINERATION, OR RECOVERY FACILITY.
| 1 | eyes_protection_mandatory |
Control Measures
*
Proprietary Ind: Y
*
Contractor Summary
*
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: EYE: MAY CAUSE MINOR TRANSIENT IRRITATION. NO
CORNEAL INJURY LIKELY. SKIN: MAY CAUSE MINOR IRRITATION, MAY CAUSE SKIN
SENSITIZATION. NOT LIKELY TO BE ABSORBED IN TOXIC AMOUNTS. INGEST: LOW IN T
OXICITY. INHALATION: RESPIRATORY TRACT IRRITATION NOT LIKELY.
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
SKIN:WASH PROMPTLY W/SOAP & WATER. INGEST:SEEK MED ASSISTANCE IMMED.
INHAL:REMOVE PERSON TO FRESH AIR. SEEK MED ATTN IF NEEDED. NOTE TO PHYS :ORAL
TOX OF THIS CMPD IS LOW, BUT THERE ARE DEFINITE PREC INHAL EFTS SHOWN IN
ANIMAL STUDIES. BECAUSE OF ITS IRRITANT PROPERTIES, PERSONS HNDLNG MATL
SHOULD AVOID CONT OF MATL WITH SKIN/EYE,(SUP DAT)
*
Handling and Disposal
*
Spill Release Procedures: ABSORB WITH INERT MATERIAL (CLAY, SAND, ETC) &
PLACE IN APPROPRIATE CONTAINERS WITH NON-SPARKING TOOLS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF MATERIAL ACCORDING TO ALL FEDERAL, STATE AND
LOCAL LAWS.
Handling And Storage Precautions: STORE IN COOL, DRY PLACE. KEEP AWAY FROM OPEN
FLAMES & HIGH TEMPS. PRACTICE GOOD CAUTION & PERSONAL CLEANLINESS TO
AVOID SKIN & EYE CONTACT.
Other Precautions: AVOID BREATHING VAPORS OF HEATED MATL., CAUTION! MAY CAUSE
EYE & SKIN IRRIT, POTENTIAL SKIN SENSIT. PREVENT CONTACT W/EYES &
SKIN. WASH THORO AFTER HNDLNG. REMOVE & WASH CONTAMD CLTHG BEFORE REUSE.
CO NTAMD LEATHER SHOES SHOULD BE DISCARDED.
*
Fire and Explosion Hazard Information
*
Flash Point Method: PMCC
Extinguishing Media: FOAM CO*2, DRY CHEMICAL OR WATER SPRAY.
Fire Fighting Procedures: NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP (FP N).
WATER SHOULD BE USED TO KEEP FIRES-EXPOS CNTNRS COOL. IF LEAK/SPILL HAS NOT
IGNIT, USE WATER SPRAY TO (SUPDAT)
Unusual Fire/Explosion Hazard: NO UNUSUAL HAZARDS.
*
*
Respiratory Protection: NONE NORMALLY NEEDED. NIOSH/MSHA APPROVED RESPIRATOR
W/VAPOR/GAS FILTER FOR PERSONAL COMFORT.
Ventilation: GOOD ROOM VENTILATIOON USUALLY ADELQUATE FOR MOST OPERATION.
Other Protective Equipment: CLEAN, BODY-COVERING CLOTHING. ANSI APPROVED
EMERGENCY EYE WASH & DELUGE SHOWER (FP N).
Work Hygienic Practices: WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health: USERS OF "L" VERSION OF SHOULD CONSULT "LR"
VERSION FOR ADDITIONAL INFORMATION (FP N). FIRE FIGHT PROC: DISPERSE VAPORS
& TO PROTECT PERSONS ATTEMPTING TO STOP LEAK. FIRST AID PROC: &
SHOULD AVOI D INHALING VAPORS.
*
Physical/Chemical Properties
*
Vapor Pres: 1
Vapor Density: >1
Spec Gravity: 1.6-1.7(H*2O=1)
Solubility in Water: SLIGHT
Appearance and Odor: PIGMENTED LIQUID; LOW ORDER.
Percent Volatiles by Volume: NIL
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: EXCESS HEATING OVER LONG PERIODS OF TIME DEGRADES
RESIN.
Materials To Avoid: STRONG OXIDIZING AGENTS, STRONG LEWIS/MINERAL ACIDS AND
CAUSTICS.
Hazardous Decomposition Products: NONE UNDER NORM USE. CO, ALDEHYDES & ACIDS
MAY BE FORMED DURING COMBUSTION.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Assigned IND: Y
Company Name: EPOOXYLITE CORP
Label Required IND: Y
Status Code: C
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Moderate
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE: EYE: MAY CAUSE MINOR TRANSIENT IRRITATION. NO
CORNEAL INJURY LIKELY. SKIN: MAY CAUSE MINOR IRRITATION. NO LIKELY TO BE
ABSORBED IN TOXIC AMOUNTS. INGESTION: LOW IN TOXICITY. INHALATION: RESPIRA
TORY TRACT IRRITATION NOT LIKELY. CHRONIC: MAY CAUSE SKIN SENSITIZATION.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IN THE CASE WHERE OVEREXPOSURE MAY EXIST, THE
USE OF AN APPROVED NIOSH-MSHA DUST RESPIRATOR OR AN AIR SUPPLIED
RESPIRATOR IS ADVISED. ENGINEERING OR ADMINISTRATIVE CONTROLS
SHOULD BE IMPLEMENTED TO CO NTROL DUST.
Ventilation:PROVIDE SUFFICIENT AREA OF LOCAL EXHAUST TO MAINTAIN
EXPOSURE BELOW THE TLV-TWA.
SHOULD BE WORN.
Other Protective Equipment:PROVIDE EYE WASH IN WORKING AREA. NORMAL
WORK CLOTHING, COVERING ARMS AND LEGS AND RUBBER OR PLASTIC APRON
SHOULD BE WORN.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER AFTER
HANDLING POTASSIUM PERMANGANATE, AND BEFORE EATING OR SMOKING. WEAR
PROPER PROTECTIVE EQUIPMENT. REMOVE CONTAMINATED CLOTHING.
Supplemental Safety and Health
SYNONYMS: PERMANGANIC ACID POTASSIUM SALT, CHAMELEON MINERAL, CONDY'S
CRYSTALS, PERMANGANATE OF POTASH,. TRADE NAME: CAIROX POTASSIUM
PERMANGNATE.
* Product Identification *
Product ID:CAIROX POTASSIUM PERMANGANATE
Preparer's Name:KENNETH KROGULSKI
* Composition/Information on Ingredients *
Ingred Name:POTASSIUM PERMANGANATE
OSHA PEL:C5 MG/M3 OF AIR
ACGIH TLV:0.2 MG/M3 OF AIR
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: POTASSIUM PERMANGANATE IS
DAMAGING TO EYE TISSUE ON CONTACT. IT MAY CAUSE SEVERE BURNS THAT
RESULT IN DAMAGE TO THE EYE. SKIN: CONTACT OF SOLUTIONS AT ROOM
TEMPERATURE MAY BE IRRITATING TO THE SK IN, LEAVING BROWN STAINS.
CONCENTRATED SOLUTIONS AT ELEVATED TEMPERATURE AND CRYSTALS ARE
DAMAGING TO THE SKIN. INHALATION: ACUTE INHALATIION TOXICITY DATA
NOT AVAILABLE. HOWEVER, AIRBORNE CONCENTRATI ONS OF POTASSIUM
PERMANGANATE IN THE FORM OF DUST OR MIST MAY CAUSE DAMAGE TO THE
RESPIRATORY TRACT. INGESTION: POTASSIUM PERMANANATE IF SWALLOWED
MAY CAUSE SEVERE BURNS TO THE MUCOUS MEMBRANES OF THE MOUTH,
THROAT, ESOPHAGUS AND STOMACH.
Effects of Overexposure:EYE: IT MAY CAUSE SEVERE BURNS THAT RESULT IN
DAMAGE TO THE EYE. SKIN: LEAVING BROWN STAINS. INGESTION: POTASSIUM
PERMANANATE IF SWALLOWED MAY CAUSE SEVERE BURNS TO THE MUCOUS
MEMBRANES OF THE MOUTH, THROAT, ESOPHAGUS AND STOMACH.
Medical Cond Aggravated by Exposure:POTASSIUM PERMANGANATE WILL CAUSE
FURTHER IRRITATION OF OPEN WOUNDS, BURNS OR MUCOUS MEMBRANES.
* First Aid Measures *
APART. DO NOT ATTEMPT TO NEUTRALIZE CHEMICALLY. SEEK MEDICAL AID
IMMEDIATELY. NOTE TO PHYSICIAN: SOLUBLE DECOMPOSTION PRODUCT ARE
ALKALINE. INSOLUBLE DECOMPOSTION PRODUCT IS BROWN MANGANESE
DIOXIDE. SKIN-IMMEDIATELY WASH CONTAMINATED AREAS WITH WATER.
REMOVE CONTAMINATED CLOTHING/FOOTWEAR. SEEK MEDICAL AID IMMEDIATELY
IF IRRITATION IS SEV ERE OR PERSISTENT. INHALATION-REMOVE PERSON
FROM ARE TO FRESH AIR. IF BREATHING HAS STOPPED, RESUSCITATE & GIVE
OXYGEN IF AVAILABLE. SEEK MEDICAL AID. INGESTION-IF CONSCIOUS, GIVE
LARGE AMOUNTS OF WAT ER. SEEK MEDICAL AID IMMEDIATELY.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:USE LARGE QUANTITIES OF WATER. WATER WILL TURN PINK
TO PURPLE IF IN CONTACT WITH POTASSIUM PERMANGANATE. DIKE TO
CONTAIN. DO NOT USE DRY CHEMICAL, CO2, HALON OR FOAMS.
Fire Fighting Procedures:IF MATERIAL IS INVOLVED IN FIRE, FLOOD WITH
WATER. COOL ALL AFFECTED CONTAINERS WITH LARGE QUANTITIES OF WATER.
APPLY WATER FROM AS FAR A DISTANCE AS POSSIBLE. WEAR SELF-CONTIANED
BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING.
* Accidental Release Measures *
Spill Release Procedures:CLEAN UP SPILLS IMMEDIATELY BY SWEEPING OR
SHOVELING UP THE MATERIAL. DO NOT RETURN SPILLED MATERIAL TO THE
ORIGINAL CONTAINER. TRANSFER TO A CLEAN METAL DRUM. EPA BANNED THE
INFORMATION"
Neutralizing Agent:NEUTRALIZE WITH SODIUM BICARBONATE TO NEUTRAL PH
*Handling and Storage *
REQUIREMENTS FOR GLASS IF OXIDIZES. PROTECT CONTAINERS FROM
PHYSICAL DAMAGE, STORE IN A COOL, DRY AREA IN CLOSED CONTAINERS.
SEGREGATE FROM ACIDS, PEROXIDES, FORMALDE HYDE, & ALL COMBUSTIBLE,
ORGANIC OR EASILY OXIDABLE MATERIALS INCLUDING
ANTI-FREEZE/HYDRAULIC FLUID.
* Physical/Chemical Properties *
HCC:D1
Boiling Pt:B.P. Text:NA
M.P/F.P Text:DECOMPOSES
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:2.7
Evaporation Rate & Reference:NA (BUTLY ACETATE=1)
Appearance and Odor:DARK PURPLE SOLID WITH A METALLIC LUSTER. ODORLESS
Percent Volatiles by Volume:NA
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CONTACT WITH PEROXIDES, FOMALDEHYDE, ANTI-FREEZE, HYDRAULIC FLUIDS, AND
ALL COMBUSTIBLE ORGANIC OR READILY OXIDIZABLE INORGANIC MATERIALS
INCLUDING METAL POWDERS WITH HYDROCHLORIC ACID, TOXIC CHLORINE GAS
IS LIBERATED.
Stability Condition to Avoid:CONTACT WITH INCOMPATIBLE MATERIEALS OR
Hazardous Decomposition Products:WHEN INVOLVED IN A FIRE, POTASSIUM
PERMANGANATE MAY LIBERATE CORROSIVE FUMES.
Conditions to Avoid Polymerization:WILL NOT OCCUR
* Toxicological Information*
EFFECTS OF OVEREXPOSURE" ACUTE OVEREXPOSURE-IRRITATING TO BODY
TISSUE WITH WHICH IT COMES INTO CONTACT. CHRONIC OVEREXPOSURE-NO
KNOWN CASES OF CHRONIC POISONING DUE TO POTASSIUM PERMANGANATE HAVE
BEEN REPORTED. PROLONGED EXPOSURE,USUALLY OVER MANY YEARS, TO
HEAVY CONCENTRATIONS OF MANGANESE OXIDES IN THE FORM OF DUST &
FUMES, MAY LEAD TO CHRONIC MANGANESE POISONINGG, CHIEFLY INVOLVING
THE CENTRAL NERVOUS SYSTEM.
* Ecological Information *
Ecological:ENTRY TO THE ENVIRONMENT: POTASSIUM PERMANGNATE HAS A LOWER
ESTIMATED LIFETIME IN THE ENVIRONMENT, BEING READILY CONVERTED BY
OXIDIZABLE MATERIALS TO INSOLUBE MANGANESE DIOXIDE (MNO2).
BIOCONCENTRATIO N POTENTIAL: IN NON-REDUCING & NON-ACIDIC
* Disposal Considerations *
Waste Disposal Methods:REDUCE POTASSIUM PERMANGANATE IN AQUEOUS
SOLUTION WITH SODIUM THIOSULFATE (HYPO), OR SOLIUM BISULFITE SALT
SOLUTION. THE THIOSULFITE OR FERROUS SALT MAY REQUIRE SOME DILUTE
SULFARIC ACID (TO PROMOTE R APID REDUCTION. IF ACID WAS USED,
NEUTRALIZE WITH SODIUM BICARBONATE TO NEUTRAL PH. DECANT OR FILTER
, AND MIX THE SLUDGE WITH SODIUM CARBONATE AND
* MSDS Transport Information *
Transport Information:U.S. DEPARTMENT OF TRANSPORTATION INFORMATION:
* Regulatory Information *
SARA Title III Information:SARA TITLE III INFORMATION: SECTION
COMPOUND AS PART OF THE CHEMICAL STRUCTURE (MANGANESE COMPOUNDS CAS
REG. NO. N/A) AND IS SUBJECT TO THE REPORTING REQUIREMENTS OF
Federal Regulatory Information:TSCA: LISTED IN THE TSCA CHEMICAL
SUBSTANCE INVENTORY. CERCLA: HAZARDOUS SUBSTANCE-REPORTABLE
SUCH AS POTASSIUM PERMANGANATE MEET THE CR ITERIA OF IGNITABLE
State Regulatory Information:MICHIGAN CRITICAL MATERIALS REGISTER: NOT
SUBSTANCE LIST: 5 F8. PENNSYLVANIA HAZARD SUBSTANCE LIST: E.
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED DUST MASK.
Ventilation:LOCAL EXHAUST REQUIRED.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:TITANIUM SULFATE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NO TOXICITY DATA AVAILABLE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:UNKNOWN.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:SKIN: REMOVE CONTAM CLOTHING. RINSE LIBERALLY W/SOAP & WATER
FOR A CONSIDERABLE PERIOD. INGEST: RINSE MOUTH SEVERAL TIMES
W/WATER, PATIENT MAY NOT SWALLOW WATER. IN CASE OF IMMINENT UNCON,
CLEAR RESPTRACT & LAY PERS ON HIS/HER SIDE IN STABLE POSITION.
ALWAYS CALL MD. EYES: RINSE LIBERALLY W/WATER FOR A PERIOD(AT LEAST
* Fire Fighting Measures *
Flash Point:NON FLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT
Unusual Fire/Explosion Hazard:
* Accidental Release Measures *
Spill Release Procedures:SWEEP INTO SUITABLE CONTAINER FOR DISPOSAL.
Neutralizing Agent:
*Handling and Storage *
USE A HOOD. ROOM TEMPERATURE.
Other Precautions:
* Physical/Chemical Properties *
HCC:C2
Vapor Pres:NOT AVAIL
Spec Gravity:NOT AVAILABLE
Appearance and Odor:SOLID. AT ROOM TEMPERATURE.
* Stability and Reactivity Data *
NONE.
Stability Condition to Avoid:
Hazardous Decomposition Products:WHEN HEATED OR BURNED: TOXIC FUMES
SOX.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE OR LANDFILL AS COMPLIES WITH FEDERAL,
STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
Control Measures
*
*
Contractor Summary
*
*
Ingredients
*
------------------------------
------------------------------
------------------------------
------------------------------
OSHA PEL: 0.2 MG/M3
------------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: YES
Effects of Exposure: ACUTE: MODERATELY TOXIC. MAY BE IRRITATING TO EYES, SKIN
& RESPIRATORY TRACT. INHAL: MAY CAUSE IRRITATION, SHORTNESS OF BREATH,
CHEST PAIN, WEAKNESS, LEG PAINS, DESTRUCTION OF LUNG TISSUE, LIVER & KID
NEY DAMAGE. CHRONIC: DANGER OF CUMULATIVE EFFECTS.
Explanation Of Carcinogenicity: CADMIUM: GROUP 2B, IARC MONOGRAPHS VOL SUPL 7,
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: RESPIRATORY CONDITIONS, LIVER OR KIDNEY
DISEASE.
ADMIN MILK/BEATEN EGG WHITES AT FREQUENT INTERVALS. INDUCE VOM IT. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCON PERSON. CALL MD. INHAL: REMOVE TO FRESH AIR.
GIVE ARTF RESP IF NECESSARY. CALL MD.
*
Handling and Disposal
*
Spill Release Procedures: DECONTAMINATE SITE. DISPOSE OF MATERIAL IN AN E.P.A.
APPROVED HAZARDOUS WASTE SITE.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE &
LOCAL REGULATIONS.
Handling And Storage Precautions: STORE TIGHTLY CLOSED IN A COOL, DRY PLACE.
PROTECT FROM MOISTURE. AVOID CONTACT WITH EYES, SKIN & CLOTHING. DO NOT
BREATHE DUST.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
*
Fire and Explosion Hazard Information
*
Extinguishing Media: WATER, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT(FP N).
Unusual Fire/Explosion Hazard: MAY EMIT TOXIC FUMES IN FIRE.
*
*
Respiratory Protection: NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N).
Ventilation: FUME HOOD.
Other Protective Equipment: LAB COAT. EMERGENCY EYE WASH & DELUGE SHOWER (FP
N).
Work Hygienic Practices: WASH THROUGHLY AFTER HANDLING.
Supplemental Safety and Health: PH: 4.2 (5% SOLUTION). CARCINOGENICITY: ON
*
Physical/Chemical Properties
*
PH: SUPDAT
Solubility in Water: PARTIALLY SOLUBLE
Appearance and Odor: SOLID BLUE METALLIC POWDER W/NO ODOR.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: UNNECESSARY EXPOS TO MOISTURE. AVOID CREATION OF
DUST.
Materials To Avoid: HYDRAZOIC ACID, ALUMINUM, SULFUR, SELENIUM, TELLURIUM,
AMMONIUM NITRATE OR OXIDIZERS.
Hazardous Decomposition Products: MAY EMIT TOXIC FUMES OF CADMIUM OXIDE,
NITROGEN OXIDES, SULFUR OXIDES IN FIRE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Company Name: HACH COMPANY
Label Required IND: Y
Status Code: C
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: STORE TIGHTLY CLOSED IN A COOL, DRY PLACE. PROTECT FROM
MOISTURE. AVOID CONTACT WITH EYES, SKIN & CLOTHING. DO NOT BREATHE DUST.
ACUTE: MODERATELY TOXIC. MAY BE IRRITATING TO EYES, SKIN & RESPIRATORY
TRACT. INHAL: MAY CAUSE IRRITATION, SHORTNESS OF BREATH, CHEST PAIN,
WEAKNESS, LEG PAINS, DESTRUCTION OF LUNG TISSUE, LIVER & KIDNEY DAMAGE.
CHRONIC: MODERATELY TOXIC. DANGER OF CUMULATIVE EFFECTS. DA NGER! CONTAINS
CADMIUM. CANCER HAZARD. AVOID CREATING DUST. CAN CAUSE LUNG & KIDNEY
DISEASE.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:ENSURE GOOD VENTILATION.
Other Protective Equipment:AVOID INHALATION.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:PETROLEUM HYDROCARBON
* Hazards Identification *
Health Hazards Acute and Chronic:MAY CAUSE IRRITATION ON PROLONGED
CONTACT WITH SKIN.
Effects of Overexposure:PROLONGED EXPOSUTE TO HIGH LEVELS OF VAPOUR CAN
CAUSE HEADACHE, DIZZINESS, NAUSEA AND SICKNESS.
* First Aid Measures *
AND WATER. INHALATION-REMOVE FROM EXPOSURE. INGESTION-GIVE WATER TO
DRINK. DO NOT INDUCE VOMITING.
* Fire Fighting Measures *
Flash Point Method:CC
Lower Limits:0.9
Upper Limits:6.0
Extinguishing Media:SAND, FOAM, DRY POWDER OR WATER SPRAY.
Unusual Fire/Explosion Hazard:MAY GIVE RISE TO TOXIC FUMES IF INVOLVED
IN A FIRE.
* Accidental Release Measures *
Spill Release Procedures:IN CASE OF SPILLAGE: ABSORB ON INERT
SUBSTRATE.
*Handling and Storage *
Handling and Storage Precautions:AVOID UNNECESSARY PERSONAL CONTACT.
GOOD HOUSEKEEPING. KEEP IN CLOSED CONTAINERS. AWAY FROM HEAT.
* Physical/Chemical Properties *
HCC:F4
Vapor Pres:CA. 2 MMHG
Vapor Density:CA. 4-5
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:INSOLUBLE.
Appearance and Odor:PALE BROWN SOFT GEL. HYDROCARBON ODOUR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS, SOME PLASTICS.
Hazardous Decomposition Products:CARBON MONOXIDE MAY BE VOLVED IN A
FIRE.
* Disposal Considerations *
Waste Disposal Methods:ACCORDING TO LOCAL REGULATIONS.
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED IN WELL VENTILATED AREA. IN
CONFINED AREAS WHERE HIGH VAPOR CONCENTRATIONS ARE EXPECTED, USE
Ventilation:USE EXPLOSION-PROOD EXHAUST SYS SUITABLE TO MAINTAIN CONC
OF VAP IN WORKPLACE ATMOSPHERE BELOW TLV/PEL'S. (SUPDAT)
Other Protective Equipment:CLOTHING ADEQUATE TO PROTECT SKIN.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
VENT:EXHAUST VAPORS SHOULD BE VENTED TO NON- EXPLOSIVE AREA.
* Product Identification *
Product ID:3-PURPOSE B-I-N PRIMER-SEALER
* Composition/Information on Ingredients *
Fraction by Wt: <4%
Ingred Name:ALUMINUM SILICATE
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HIGH CONCENTRATION OF VAPOR MAY CAUSE
HEADACHE, DROWSINESS, NAUSEA AND DIZZINESS AS WELL AS IRRITATION OF
EYES AND RESPIRATORY TRACT. PROLONGED CONTACT WITH SKIN MAY CAUSE
IRRITATION. INGESTION CAN CA USE NAUSEA AND VOMITING.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS
Medical Cond Aggravated by Exposure:NONE KNOWN
* First Aid Measures *
First Aid:EYES:IRRIGATE WITH COPIOUS AMOUNTS OF CLEAR WATER FOR AT
WATER. INHAL:MOVE SUBJECT TO FRESH AIR; MAINTAIN BREATHING; OBTAIN
MEDICAL ATTE NTION IMMEDIATELY. INGEST:CALL PHYSICIAN OR POISON
CONTROL CENTER IMMEDIATELY.
* Fire Fighting Measures *
Lower Limits:3.3%
Extinguishing Media:"ALCOHOL" FOAM, CARBON DIOXIDE, DRY CHEMICAL,,
WATER FOG, SAND.
Fire Fighting Procedures:NONE. USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. PROVIDE
ADEQUATE VENTILATION OR USE RESPIRATORY PROTECTION IN CONFINED
AREAS. CLEAN AREA WITH ABSORBENT MATERIAL, SAND OR RAGS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL PLACE AWAY FROM HIGH
HEAT, OPEN FLAMES, SPARKS AND OXIDIZING AGENTS. USE ONLY WITH
ADEQUATE VENTILATION.
Other Precautions:AVOID PROLONGED BREATHING OF VAPOR OR SPRAY MIST AND
PROLONGED CONTACT WITH SKIN. DO NOT TAKE INTERNALLY. KEEP OUT OF
DIRECT SUNLIGHT. KEEP CONTAINER CLOSED. DRUM SHOULD BE GROUNDED AND
BONDED WHEN PO URING.
* Physical/Chemical Properties *
HCC:F3
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:CO IN INCOMPLETE COMBUSTION.
* Disposal Considerations *
Waste Disposal Methods:DRIED PAINT CAN BE DISPOSED OF IN TRASH. DISPOSE
OF LIQUID PAINT IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:GENERAL/LOCAL EXHAUST VENTILATION.
Other Protective Equipment:PROTECTIVE CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
SPILLS CONT'D: (3) TREAT AT AN ACCEPTABLE WASTE TREATMENT FACILITY.
* Product Identification *
Product ID:GS-1 FLUORESCENT ADDITIVE
* Composition/Information on Ingredients *
Ingred Name:FLUORESCENT ADDITIVE
Ingred Name:LUBRICATING OIL
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION. INHALATION:
NONE EXPECTED UNDER NORMAL USE. INGESTION: GI IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
Medical Cond Aggravated by Exposure:EXPOSURE ISN'T EXPECTED TO
CONTRIBUTE TO, WORSEN/AGGRAVATE ANY EXISTING MEDICAL CONDITIONS.
* First Aid Measures *
First Aid:EYES: FLUSH W/WATER. SKIN: WASH W/SOAP & WATER. INGESTION:
DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES. NOTE
TO PHYSICIAN: TREATMENT SHOULD BE DIRECTED AT PREVENTING
ABSORPTION, ADMIN ISTERING TO THE SYMPTOMS AS THEY OCCUR &
PROVIDING SUPPORTIVE THERAPY.
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:DRY CHEMICAL, CO2/CHEMICAL FOAM.
Fire Fighting Procedures:WEAR SCBA APPROVED BY NIOSH & IN POSITIVE
PRESSURE MODE W/FULL PROTECTIVE CLOTHING. AVOID USING WATER ON
BURNING MATERIALS TO REDUCE SPLATTERING & SPREADING.
Unusual Fire/Explosion Hazard:MAY LIBERATE IRRITATING/TOXIC VAPORS
DURING COMBUSTION/DECOMPOSITION.
* Accidental Release Measures *
Spill Release Procedures:STOP DISCHARGE & CONTAIN MATERIAL. USE
ABSORBENTS SUCH AS FULLER'S EARTH, CLAY/OTHER SYNTHETIC ABSORBENTS.
PLACE IN SUITABLE CONTAINER FOR DISPOSAL. (1) RECYCLE/REWORK, IF
FEASIBLE (2) INCINERATE AT A N AUTHORIZED FACILITY (SEE SUPP)
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL-VENTILATED
AREA. DON'T STORE NEAR HEAT/OTHER IGNITION SOURCES. KEEP CONTAINERS
TIGHTLY CLOSED TO AVOID CONTAMINATION.
Other Precautions:HOT ORGANIC CHEMICAL VAPORS/MISTS CAN SUDDENLY & W/O
WARNING COMBUST WHEN MIXED W/AIR. AVOID BREATHING VAPORS/MIST.
* Physical/Chemical Properties *
Vapor Pres:<1
Vapor Density:>1
Evaporation Rate & Reference:(BU AC =1): <1
Solubility in Water:INSOLUBLE
Appearance and Odor:DARK REDDISH LIQUID W/OIL LIKE ODOR.
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS & REDUCING AGENTS.
Stability Condition to Avoid:HEAT & OTHER IGNITION SOURCES.
Hazardous Decomposition Products:THERMAL: SMOKE, SOOT, CO, CO2.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:FOLLOW THE OSHA RESPIRATORY REGULATIONS FOUND IN
NECESSARY.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
AIRBORNE CONCENTRATIONS BELOW THE PERMISSIBLE EXPOSURE LIMITS.
FACESHIELD .
Other Protective Equipment:ANSI APPRVD EMER EYE WASH & DELUGE SHOWER .
WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
OSHA PEL:2 PPM
Ingred Name:WATER
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DANGER! STRONG OXIDIZER. CNTCT W/OTHER
MATL MAY CAUSE A FIRE. CORROSIVE. CAUSES EYE & SKIN BURNS. CAUSES
DIGESTIVE & RESP TRACT BURNS. ACUTE: EYE:CAUSES SEV EYE BURNS. MAY
CAUSE IRREVERSIBLE EYE INJUR Y. SKIN: MAY CAUSE SEV SKIN IRRIT.
CAUSES SKIN BURNS. MAY CAUSE DEEP, PENETRATING ULCERS OF THE SKIN.
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:INGEST: CAUSES GI TRACT BURNS. MAY
CAUSE PERFORATION OF THE DIGESTIVE TRACT. INHAL: MAY BE FATAL IF
INHALED. EFTS MAY BE DELAYED. MAY CAUSE IRRIT OF THE RESP TRACT
W/BURNING PAIN IN THE NOSE& THROAT, COUGHING, WHEEZING,
SHORTNESSOF BRTH & PULM EDEMA. CHRONIC: RPTD INHAL MAY CAUSE
CHRONIC BRONCHITIS. REPEATED EXPOS MAY CAUSE EROSION OF TEETH.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
LIFTING THE UPPER & LOWER LIDS. GET MED AID IMMED. DO NOT ALLOW
VICTIM TO RUB/KEEP EYES CLSD. SKIN:FLUSH W/PLENTY OF SOAP & H*2O
AID IF IRRIT DEVELOPS/PERSISTS. WASH CLTHG BEFORE REUSE. INGEST:DO
NOT INDUCE VOMIT & SEEK IMMED MED ADVICE. INHAL:REMOVE FROM EXPOS
TO FRESH AI R IMMED. IF NOT BRTHG, GIVE ARTF RESP. IF BREATHING IS
DIFFICULT, GIVE OXYGEN. GET MEDICAL AID. NOTES TO MD:TREAT
SYMPTOMATICALLY & SUPPORTIVELY. NO SPECIFIC ANTIDOTE EXISTS.
* Fire Fighting Measures *
Extinguishing Media:SUBSTANCE IS NONCOMBUSTIBLE; USE AGENT MOST
APPROPRIATE TO EXTINGUISH SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:GENERAL INFO: USE PROPER PERSONAL PROT
EQUIPMENT AS INDICATED IN PERS PROT EQUIP SECTION.
SPILLS/LEAKS:ABSORB SPILL W/INERT MATERIAL, (E.G., DRY SAND OR
EARTH), THEN PLACE INTO A CHEMICAL WASTE CONTAI NER. USE H*2O SPRAY
TO DISPERSE THE GAS/VAPOR.
Neutralizing Agent:SPILL WITH SODIUM BICABONATE.
*Handling and Storage *
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION. STORE
IN A COOL, DRY, WELL-VENTILATED AREA AWAY FROM INCOMPATIBLE
SUBSTANCES.
Other Precautions:DO NOT GET ON SKIN OR IN EYES. DO NOT INGEST OR
INHALE.
* Physical/Chemical Properties *
Vapor Pres:6.8
pH:1.0
Solubility in Water:COMPLETELY SOLUBLE
Appearance and Odor:CLEAR OR YELLOWISH TRANSPARENT LIQUID. STRONG ACRID
ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
PROTECTION GUIDE FOR SPECIFICS. REACTS EXPLOSIVELY W/ORG MATLS &
COMBUSTIBLE MATLS.
Stability Condition to Avoid:HIGH TEMPERATURES, INCOMPATIBLE MATERIALS,
MOISTURE, REDUCING AGENTS.
Hazardous Decomposition Products:NITROGEN OXIDES.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE
Ventilation:AS REQUIRED TO CONTROL TLV IN AIR.
Other Protective Equipment:NONE
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
III)
Ozone Depleting Chemical:1
Ingred Name:SILICONE FLUID
Fraction by Wt: 5.0%
Ingred Name:DICHLORODIFLUOROMETHANE (SARA III)
Ozone Depleting Chemical:1
* Hazards Identification *
Effects of Overexposure:AT HIGH VAPOR LEVELS,MAY PRODUCE ANESTHESIA
* First Aid Measures *
First Aid:REMOVE PATIENT FROM AREA OF HIGH CONCENTRATION
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:N.A.
* Accidental Release Measures *
Spill Release Procedures:MOP ON WIPE UP WITH SOLVENTS,THEN CLEAN WITH
DETERGENT & WATER.
*Handling and Storage *
OUT OF REACH OF CHILDREN:CAN IS UNDER PRESS.
Other Precautions:DO NOT STORE NEAR HEAT & OPEN FLAME.EXPOSURE TO
OFF SKIN.
* Physical/Chemical Properties *
HCC:V2
NRC/State Lic Num:NOT RELEVANT
Vapor Pres:0
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR LIQUID-ETHERAL ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
HOT METALS,ELECTRIC ARCS, OPEN FLAMES
Stability Condition to Avoid:HOT METALS,OPEN FLAMES,WELDING ARCS
Hazardous Decomposition Products:HYDROGEN CHLORIDE,PHOSGENE,HYDROGEN
FLUORIDE
* Disposal Considerations *
Waste Disposal Methods:DO NOT INCINERATE OR PUNCTURE EMPTY CAN. DUMP
INTO AN APPROVED LANDFILL SITE.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH APPROVED RESPIRABLE FUME RESPIRATOR OR
AIR SUPPLIED RESPIRATOR WHEN WELDING IN CONFINED SPACE OR WHERE
LOCAL EXHAUST OR VENTILATION DOES NOT KEEP EXPOSURE BELOW TLV.
Ventilation:USE ENOUGH VENT, LOC EXHST AT ARC OR BOTH TO KEEP FUMES &
GASES BELOW TLV IN WORKER'S BRTHG ZONE & GENERAL AREA.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . MAY
INCL ARM PROTECTOR, APRON, HAT, SHOULDER PROT & DARK SUBSTANTIAL
CLTHG.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
"CUTTING & WELDING PROCESS" PUB BY NFPA, BATTERYMARCH PARK, QUINCY,
* Product Identification *
* Composition/Information on Ingredients *
Fraction by Wt: 1-2%
OSHA PEL:5 MG/M3 DUST, C
ACGIH TLV:5 MG/M3 DUST
Fraction by Wt: <1%
Ingred Name:SODIUM FLUOROALUMINATE; (CRYOLITE)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CALCIUM FLUORIDE; (FLUORSPAR)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POTASSIUM FLUOROSILICATE; (POTASSIUM SILICA FLUORIDE)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM FLUORIDE (CERCLA)
OSHA PEL:2.5 PPM (F)
ACGIH TLV:2.5 MG/M3 (F)
Ingred Name:SILICON; (SI & SIO*2)
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (MINERAL SILICATES)
OSHA PEL:N/K
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
Ingred Name:MAGNESIUM OXIDE; (MAGNESIUM)
Ingred Name:IRON
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:HAZ DECOMP PROD: PROCESS, PROCS & CONSUMABLES USED.
REASONABLY EXPECTED DECOMP PRODS FROM NORM USE INCL COMPLEX (ING
PROCESSES" FROM AWS. FOR MORE COMPLETE INFO, CNTCT NEHC .
Ingred Name:EFTS OF OVEREXP: SMOKING, ETC. FOR COMPLETE INFO ON HEALTH
HAZARDS, CONTACT NEHC .
Ingred Name:FIRST AID PROC: DETECTABLE PULSE, BEGIN CPR. IMMED CALL MD.
FOR ARC BURN, APPLY COOL, CLEAN COMPRESS & CALL MD.
Ingred Name:EYE PROT: & FULL LENGTH FACESHIELDW/FILTER LENS. AS RULE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:FUMES & GASES CAN BE DANGEROUS TO
HLTH. ELEC SHOCK CAN KILL. ARC RAYS CAN INJURE EYES & BURN SKIN.
NOISE CAN DMG HEARING. ACUTE OVEREXP TO GASES, FUMES & DUST MAY
CAUSE IRRIT OF EYES, LUNGS, NOSE & TH ROAT. SOME TOX GASES ASSOC
W/WELDING MAY CAUSE PULM EDEMA, ASPHY & DEATH. ACUTE OVEREXP MAY
INCL SIGNS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ: IARC MONO,
TO BE CARCIN.
Effects of Overexposure:HLTH HAZ: & SYMPS SUCH AS WATERY EYES, NOSE &
THROAT IRRIT, HDCH, DIZZ, DFCLTY BRTHG, FREQUENT COUGH/CHEST PAIN.
CHRONIC: EFTS OF CHRONIC OVEREXP TO AIR CONTAMINANTS MAY LEAD TO
THEIR ACCUM IN LUNGS, CNDTN WHICH MAY BE SEEN AS DENSE AREAS ON
CHEST X-RAYS. X-RAY CHANGES MAY BE CAUSED BY NON-WORK FACTORS SUCH
Medical Cond Aggravated by Exposure:INDIVIDUALS W/ALLERGIES OR IMPAIRED
RESP FUNC MAY HAVE SYMPS WORSENED BY EXPOS TO WELDING FUMES.
HOWEVER, SUCH REACTION CANNOT BE PREDICTED DUE TO THE VARIATION IN
COMPOSITION & QTY OF DECOMP PRODS.
* First Aid Measures *
First Aid:INGEST:CALL MD IMMED . EYES:IMMED FLUSH W/POTABLE WATER FOR
OF WATER. CALL MD . IN CASE OF EMER CALL FOR MED AID. E MPLOY FIRST
AID TECHNIQUE REC BY RED CROSS. INHAL:IF BRTHG DFCLT, GIVE OXYG &
CALL MD. FOR ELEC SHOCK, DISCONNECT & TURN OFF POWER. IF NOT BRTHG,
* Fire Fighting Measures *
Extinguishing Media:USE EXTINGUISHING MEDIA RECOMMENDED FOR BURNING
MATERIALS AND FIRE SITUATION.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . ONLY PACKAGING FOR THIS PRODUCT WILL BURN.
Unusual Fire/Explosion Hazard:PROD WILL NOT BURN. HOWEVER, WELDING ARCS
WELDING & CUTTING" & "SAFE PRACTICES" CODE:SP, (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:NOT APPLICABLE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:READ AND UNDERSTAND MANUFACTURER'S
INSTRUCTIONS & PRECAUTIONARY LABEL ON THIS PRODUCT.
TRAIN WELDER TO KEEP HEAD OUT OF FUMES. TRAIN WELDER NOT TO TOUCH
LIVE ELEC PART S & TO INSULATE SELF FROM WORK & GROUND.
* Physical/Chemical Properties *
Appearance and Odor:TUBULAR STEEL WIRE CONTAINING MINERALS AND ALLOYS;
ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE CURRENTLY KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WELDING FUMES & GASES CANNOT BE
CLASSIFIED SIMPLY. COMPOSITION & QTY OF BOTH DEPEND ON MATL BEING
* Disposal Considerations *
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSABLE CONTAINER OR
LINER IN AN ENVIRONMETNALLY ACCEPTABLE MANNER IN FULL COMPLIANCE
WITH FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED ORGANIC VAPOR RESPIRATOR
WHEN VAPORS AREA GENERATED ABOVE THE PERMISSIBLE LIMIT.
Ventilation:LOCAL EXHAUST TO CONTROL TO RECOMMENDED PEL.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . COVERALLS, APRONS, BOOTS - AS NEC TO
(SUPDAT)
Work Hygienic Practices:SHOWER AFTER HANDLING PRODUCT. CLEAN CLOTHING
SHOULD BE WORN DAILY.
Supplemental Safety and Health
EFTS OF OVEREXP:TOLUENE APPEARS ON THE NAVY LIST OF OCCUP CHEM REPRO
HAZARDS. SEEK CONSULTATION FROM APPROP HLTH PROFESSIONALS
CONCERNING LATEST HAZARD LIST INFO & SAFE HANDLING & EXPOSURE INFO
. OTHER PROT EQUIP:PREVENT SKIN CONTACT.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:VM & P NAPHTHA; (ALIPHATIC HYDROCARBONS)
Fraction by Wt: 6-8%
Fraction by Wt: <0.1%
Ingred Name:ETHANE, 1,1,1-TRICHLORO-; (1,1,1-TRICHLOROETHANE) (OZONE
Ozone Depleting Chemical:1
Fraction by Wt: 4-6%
Ingred Name:P-DIOXANE; (DIETHYLENE DIOXIDE) (DIETHYLENE ETHER)(SARA
Ingred Name:CARBON BLACK
Fraction by Wt: 2+/-0.5%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:SKIN:PRLNG/RPTD CONT OF PROD MAY
CAUSE IRRIT. EYE:DIRECT CONT OF PROD CAN CAUSE IRRIT.
INHAL:VAP/MIST CAN CAUSE HDCH, NAUS, IRRIT OF NOSE, THROAT & EYES.
MAY PRDCE CNS DEPRESS. INGEST:POIS IF SW ALLOWED. MAY RSLT IN
VOMIT, ASPIR OF VOMITUS INTO LUNGS CAUSES ASPIR PNEUM. CHRONIC:MAY
CAUSE DMG TO (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:CNS, RESP SYS, EYES & SKIN.
CHLOROCARBON MATLS HAVE PRDCD SENSIT OF MYOCARDIUM TO EPINEPHRINE
IN LAB ANIMALS & COULD HAVE SIMILAR EFTS IN HUMANS. ADRENOMIMETICS
(E.G., EPINEPHRINE) MAY BE CON TRAINDICATED EXCEPT FOR
LIFE-SUSTAININGUSES IN HUMANS ACUTELY/CHRONICALLY EXPOS TO
CHLOROCARBONS . NOTE: (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:SKIN:WASH AFFECTED AREAS W/WATER WHILE REMOVING CONTAM CLTHG.
GET IMMED MED ATTN. LAUNDER CONTAM CLTHG BEFORE REUSE. EYES:FLUSH
INGEST: DO NOT INDUCE VOMIT. CALL MD IMMED. NEVER GIVE
FLUIDS/INDUCE VOMIT IF VICTIM IS UNCONSCIOUS/HAVING CONVLS.
INHAL:MOVE TO FRESH AIR. AID IN BRTHG, IF NEC & GET MED ATTN.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1.3%
Extinguishing Media:FOAM, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA &
FULL PROTECTIVE EQUIPMENT . BLANKET VAPOR W/EXTINGUISHING MEDIA.
Unusual Fire/Explosion Hazard:THERMAL DECOMP PRODS MAY INCL HCL &
PHOSGENE . FLAMM VAP CAN FORM EXPLO MIXT W/AIR. CORR VAP PRDCD BY
THERMAL DECOMP OF CHLORINATED HYDROCARBONS.
* Accidental Release Measures *
Spill Release Procedures:SPILLS SHOULD BE CONTAINED, SOLIDIFIED &
PLACED IN A RCRA LICENSED FACILITY. HANDLING EQUIPMENT TO BE
GROUNDED TO PREVENT SPARKING. WEAR NIOSH/MSHA APPROVED RESPIRATORS,
EYE & SKIN PROTECTION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NO SMOKING IN AREA OF USE. DO NOT USE IN GENERAL
VICINITY OF ARC WELDING, OPEN FLAMES OR HOT SURFACES. HEAT &/OR UV
RADIATION MAY CAUSE THE FORMATION OF HCL &/OR PHOSGENE .
* Physical/Chemical Properties *
Vapor Density:4.5
Spec Gravity:1.6
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK VISCOUS LIQUID; IRRITATING ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING, REDUCING AGENTS IN CONJUNCTION W/HEAT.
Stability Condition to Avoid:KEEP AWAY FROM HEAT, SPARKS OR DIRECT
SUNLIGHT. AVOID USING THIS PROD W/EQUIP CONTAINING ANY
ALUMINUM/ZINC COMPONENTS.
Hazardous Decomposition Products:OXIDES OF CARBON, HYDROCHLORIC ACID &
VERY SMALL AMOUNTS OF PHOSGENE & CHLORINE.
* Disposal Considerations *
Waste Disposal Methods:SEND WASTE TO LICENSED RECLAIMERS OR INCINERATE
IN A RCRA LICENSED FACILITY. DO NOT DISCHARGE INTO WATERWAYS OR
SEWER SYSTEMS. ANY DISPOSAL PRACTICE MUST BE IN COMPLIANCE
W/FEDERAL, STATE & LOCAL REGU LATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH APPROVED RESPIRATORS IN DUSTY AREAS
WHICH EXCEED THE TLV.
Ventilation:PROVIDE LOCAL EXHAUST VENTILATION TO KEEP BELOW TLV
Other Protective Equipment:MAINTAIN MN CONCENTRATIONS <5MG/CUM
Supplemental Safety and Health
* Product Identification *
Product ID:MANGANESE CARBONATE, REG/EXTRA FINE GRIND
* Composition/Information on Ingredients *
Ingred Name:MANGANESE CARBONATE
ACGIH TLV:5MG/CUM
* Hazards Identification *
Effects of Overexposure:EXPOSURE TO HIGH CONCENTRATIONS OF MANGANESE
FUMES MAY CAUSE METAL FUME FEVER.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. INGESTION: INDUCE VOMITING,
DRINK WATER AND CONSULT PHYSICIAN.
* Fire Fighting Measures *
Extinguishing Media:CO2, DRY CHEMICAL OR WATER EXTINGUISHERS
Unusual Fire/Explosion Hazard:NO FIRE HAZARD AS SUCH.
* Accidental Release Measures *
Spill Release Procedures:DOESN'T PRESENT ANY UNUSUAL HAZARD OTHER THAN
WHAT IS DESCRIBED IN HEALTH HAZARDS. SEP OR SHOVEL INTO WASTE
DISPOSAL CONTAINER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN CLEAN DRY AREA.
* Physical/Chemical Properties *
Appearance and Odor:LIGHT TAN CRYSTAL
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:COMPLY WITH LOCAL REGULATIONS PER SOLIDS
DISPOSAL.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED DUST MASKS.
Ventilation:VENTILATION MAY BE USED TO CONTROL OR REDUCE AIRBORNE
CONCENTRATIONS.
Other Protective Equipment:EMERGENCY EYE WASH AND DELUGE SHOWER .
Work Hygienic Practices:DO NOT WEAR CONTACT LENSES WHEN WORKING WITH
THIS PRODUCT.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Product ID:SET CONCRETE RESURFACER
* Composition/Information on Ingredients *
Ingred Name:SILICATE, PORTLAND CEMENT
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
OSHA PEL:SEE TABLE Z3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INAHL:NUISANCE DUST MAY CAUSE
TEMPORARY BUT REVERSIBLE RESPIRATORY PROBLEMS. EYE:MAY CAUSE SEVERE
IRRITATION WITH CORNEAL INJURY. ABRASIVE ACTION MAY CAUSE DAMAGE TO
THE OUTER SURFACE OF THE EYE. SKIN :IN COMBINATION WITH MOISTURE,
MAY CAUSE SEVERE ALKALI BURNS. INGEST:MAY CAUSE NAUSEA.
CHRONIC:REPEATED (EFTS OF OVEREXP
Explanation of Carcinogenicity:CRYSTALLINE SILICA:GROUP 2A (IARC).
Effects of Overexposure:HLTH HAZ:INHALATION OF RESPIRATORY SILICA IN
EXCESS OF TLV OVER EXTENDED PERIODS CAN RESULT IN IRREVERSIBLE
FIBROSIS OF THE LUNGS (SILICOSIS). THERE IS LIMITED EVIDENCE OF
CARCINOGENICITY OF CRYSTALLI NE SILICA TO HUMANS.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:INHAL:MOVE TO FRESH AIR. EYE:FLUSH WITH COPIOUS AMOUNTS OF
WATER. CALL MD. SKIN:WASH WITH SOAP & WATER. INGEST:CALL MD.
* Fire Fighting Measures *
Extinguishing Media:USE EXTINGUISHING AGENT SUITABLE FOR TYPE OF
SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:
* Accidental Release Measures *
Spill Release Procedures:AVOID CREATING DUST DURING CLEAN-UP OF SPILLS
OR LEAKS OF THIS MATERIAL. SWEEP UP AND RETURN FOR REUSE OR
DISCARD.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM WET DAMP CONDITIONS.
Other Precautions:
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:SLIGHT
Appearance and Odor:WHITE GRANULAR POWDER, ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:ACIDS.
Hazardous Decomposition Products:NONE.
* Disposal Considerations *
Waste Disposal Methods:THIS PRODUCT WHEN HARDENED AND DISPOSED OF, IS
NOT LISTED AS HAZARDOUS WASTE IN FEDERAL REGULATIONS. DISPOSE IN A
LANDFILL IN ACCORDACNE WITH LOCAL, STATE, AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE
OR AN EMERGENCY OCCURS; WEAR AN MSHA/NIOSH APPROVED RESPIRATOR OR
AN AIR-SUPPLIED RESPIRATOR OR SCBA, AS REQUIRED. USE IN ACCORDANCE
Ventilation:USE ADEQUATE MECHANICAL VENTILATION OR LOCAL EXHAUST TO
MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:PROTECTIVE CLOTHING SHOULD BE WORN.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
MSDS WAS ORIGINALLY WRITTEN BY ACROS ORGANICS, WAS MODIFIED BY FISHER
* Product Identification *
Product ID:HEXYL ALCOHOL
* Composition/Information on Ingredients *
Ingred Name:HEXANOL
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION OF VAPORS MAY CAUSE
RESPIRATORY IRRITATION. CONTACT MAY CAUSE SKIN IRRITATION AND/OR
BURNS TO EYES. NO DATA GIVEN FOR INGESTION. CHRONIC: NONE SPECIFIED
BY MANUFACTURER.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUEPECTED CARCINOGEN.
Effects of Overexposure:INHALED-COUGHING, WHEEZING, SHORTNESS OF
BREATH. EYES-BURNING SENSATION, PAIN, TEARING. SKIN-REDNESS, RASH,
DISCOMFORT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHALED-REMOVE TO FRESH AIR. TREAT SYMPTOMATICALLY. IF
SYMPTOMS PRESENT, GET MEDICAL ATTENTION. SKIN-FLUSH SKIN WITH
MINUTES. GET MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL
FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE GEAR. COOL FIRE EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. ABSORB
MATERIAL IN VERMICULITE OR OTHER SUITABLE ABSORBANT MATERIAL AND
PLACE IN A CONTAINER. DISCHARGE, TREATMENT, OR DISPOSAL MAY BE
SUBJECT TO LOCAL, STATE AND FE DERAL REGULATIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE AWAY FROM
SOURCES OF IGNITION AND STRONG OXIDIZING AGENTS.
Other Precautions:CLASSIFIED AS A COMBUSTIBLE LIQUID (FOR STORAGE).
* Physical/Chemical Properties *
HCC:F4
Solubility in Water:SLIGHT
Appearance and Odor:COLORLESS LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:COMBUSTION WILL PRODUCE CARBON
MONOXIDE AND CARBON DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF BY INCINERATION OR CONTRACT WITH
LICENSED CHEMICAL DISPOSAL COMPANY. DISPOSE OF IAW APPLICABLE
LOCAL, STATE AND FEDERAL ENVIRONMENTAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER. IF ENGINEERING
CONTROLS FAIL OR NON-ROUTINE USE OR AN EMERGENCY OCCURS; WEAR AN
MSHA/NIOSH APPROVED RESPIRATOR OR AN AIR-SUPPLIED RESPIRATOR OR
Ventilation:USE ADEQUATE MECHANICAL VENTILATION OR LOCAL EXHAUST TO
MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER. DLA-HMIS:
PROVIDE EYE WASH STATION & SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
KEY1=T6. PART A OF 2 COMPONENT KIT. SEE PNI C FOR COMPONENT B OF KIT.
PNI A REPRESENTS A FORMULA CHANGE TO PNI C/PART B.
* Product Identification *
Kit Part:Y
Preparer's Name:RBW
* Composition/Information on Ingredients *
Other REC Limits:NONE RECOMMENDED
Ingred Name:MANUFACTURER LISTS NOTHING FURTHER UNDER "INGREDIENTS"
IMPLYING NO MORE HAZARDOUS INGREDIENTS PER HAZ COM STD.
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EXPOSURE MAY CAUSE CYANOSIS
THROUGH SKIN ABSORPTION, INHALATION OR INGESTION. HARMFUL IF
ABSORBED THROUGH SKIN. CHRONIC: PROLONGED/REPEATED EXPOSURE MAY
CAUSE CANCER.
Explanation of Carcinogenicity:4,4'-METHYLENE BIS (2-CHLOROANILINE) IS
LISTED BY NTP (AC) & IARC (2A) AS A ANTICIPATED/SUSPECTED
CARCINOGEN.
Effects of Overexposure:SKIN-CYANOSIS. INHALED-CYANOSIS.
INGESTED-CYANOSIS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
SKIN-WASH WITH MILD SOAP & WATER. CONSULT A PHYSICIAN.
INHALED-REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION.
INGESTED-CONSULT A PHYSICIAN.
* Fire Fighting Measures *
Flash Point:NON-FLAMMABLE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:WATER FOG, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL FIRE FIGHTER'S PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:ASHES & VAPOR MAY CONTAIN CARCINOGENS.
* Accidental Release Measures *
Spill Release Procedures:WEAR APPROPRIATE PERSONAL PROTECTIVE GEAR.
COVER SPILL WITH ABSORBANT. SCOOP INTO CONTAINER. CLEAN-UP RESIDUE
WITH 1,1,1-TRICHLOROETHANE.
Neutralizing Agent:1,1,1-TRICHLOROETHANE.
*Handling and Storage *
Handling and Storage Precautions:AVOID ALL SKIN CONTACT & INGESTION.
REMOVE PROTECTIVE CLOTHING PRIOR TO EATING OR SMOKING.
Other Precautions:THIS PRODUCT CONTAINS A SUBSTANCE(S) SUBJECT TO THE
* Physical/Chemical Properties *
HCC:T3
Solubility in Water:NEGLIGIBLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OXIDES OF CARBON & NITROGEN.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:EPA HAZARDOUS WASTE. DISPOSE OF IN ACCORDANCE
WITH LOCAL, STATE AND FEDERAL ENVIRONMENTAL REGULATIONS. RQ=3 LBS
(MBOCA).
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF SOLID METAL ALLOYS ARE CONVERTED IN MFG (INCL
GRINDING, HIGH TEMP CUTTING & WELDING) PROCESSES TO DUSTS, FUMES,
GASES OR MISTS, & VENT IS NOT ADEQ TO MAINTIAN EXPOS BELOW LIMITS
SPECIFIED, THEN RES P PROT SHOULD BE USED. USE ONLY (SUPDAT)
Ventilation:IF SOLID METAL ALLOYS ARE CONVERTED TO DUSTS, FUMES OR
MISTS, MAINTAIN WORKING ENVIRONMENT BELOW EXPOS LIMITS BY(SUPDAT)
Other Protective Equipment:WHEN CUTTING, GRINDING OR WELDING, WEAR
SHADE (SUPDAT)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HAZ DECOMP PRODS:METALS, CHROMATES, FLUORIDES & COMPLEX METALLICS. THE
GASES MAY INCL CO, OZONE & NOX. OTHER PREC:THAT USE OF MATL DOES
NOT CREATE EXPOS WHICH EXCEED LEVELS SPECIFIED. RESP PROT:NIOSH/
OTHER PROT EQUIP:FROM AWS PUBLICATION F2.2.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:CHROMIUM (SARA III)
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:IRON (III) OXIDE;(IRON)
Ingred Name:NICKEL (SARA III)
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:NAUSEA, TIGHTNESS OF CHEST,
FEVER, IRRITATION OF EYES, NOSE, THROAT AND SKIN; LOSS OF
CONSCIOUSNESS DUE TO WELDING GASES OR LACK OF OXYGEN.
CHRONIC:ADVERSE EFFECTS MAY INCLUDE SKIN SENSITIZATION ,
NEUROLOGICAL DAMAGE & RESPIRATORY DISEASES (BRONCHIAL ASTHMA, LUNG
FIBROSIS, OR PNEUMOCONIOSIS). (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NICKEL:ANTICIPATED CARCINOGEN (NTP),
GROUP 1 (IARC). CHROMIUM:KNOWN CARCINOGEN (NTP), GROUP 1 (IARC).
NICKEL & CHROMIUM ARE CONSIDERED POSSIBLE CARCINOGENS. RECENT
EPIDEMIOLOGICAL STUDIES OF WORKERS MELTING AND WORKING ALLOYS
CONTAINING NICKEL/CHROMIUM HAVE FO UND NO INCREASED RISK OF CANCER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL:MOVE FROM EXPOSURE AND GET MD IMMEDIATELY. GIVE OXYGEN
IF VICTIM IS CONSCIOUS. IF NOT BREATHING, RESUSCITATE IMMEDIATELY.
SKIN:FLUSH WITH COPIOUS AMOUNTS OF WATER. CALL MD IMMEDIATELY . EY
INGEST:CALL MD IMMEDIATELY .
* Fire Fighting Measures *
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MATERIAL IS NONFLAMMABLE; HOWEVER,
WELDING ARCS AND SPARKS CAN IGNITE FLAMMABLE LIQUIDS AND VAPORS AND
COMBUSTIBLE LIQUIDS.
* Accidental Release Measures *
Spill Release Procedures:IF MATERIAL IS RELEASED OR SPILLED FROM
CUTTING, GRINDING OR WELDING OPERATIONS, VACUUM RESIDUE INTO
SUITABLE CONTAINERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:MATERIAL IN SOLID FORM DOES NOT
REQUIRE SPECIAL PRECAUTIONS IN HANDLING AND STORING. HOWEVER, USE
INDUSTRIAL HYGIENE AIR MONITORING TO ENSURE (SUPDAT)
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:N1
Spec Gravity:7.9
Solubility in Water:0
Appearance and Odor:GREY METALLIC ODORLESS SOLID METALS SHAPED AS WIRE,
ROD OR STRIP.
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID ACIDS. CONTACT WITH MINERAL ACIDS WILL RELEASE HYDROGEN-A VERY
READILY FLAMMABLE GAS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:FUMES/GASES FROM WELDING & HIGH TEMP
CUTTING CNTN CONSTITUENTS DIFFERENT FROM INGREDS & MAY INCL OXIDES
OF THE (SUPDAT)
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:ORGANIC VAPOR TYPE
Ventilation:GENERAL-MECHANICAL RECOMMENDED
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
* Hazards Identification *
Effects of Overexposure:IRRITATES SKIN & EYES.MAY CAUSE SLIGHT
ANESTHESIA,HEADACHES,ETC.
* First Aid Measures *
First Aid:FLUSH WITH WATER.INHALATION-REMOVE TO FRESH AIR.OBTAIN
MEDICAL ATTENTION.
* Fire Fighting Measures *
Lower Limits:1.0
Upper Limits:7.0
Extinguishing Media:CO*2 OR FOAM
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING WRN
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:USE ABSORBENT MATERIAL TO COLLECT AND CONTAIN
FOR SALVAGE OR DISPOSAL
*Handling and Storage *
Handling and Storage Precautions:PRODUCT IS FLAMMABLE.USE REASONABLE
CARE.
Other Precautions:NONE
* Physical/Chemical Properties *
HCC:F3
Vapor Density:>1.0
Spec Gravity:0.9
Evaporation Rate & Reference:<1.0(ETHER)
Solubility in Water:<0.1
Appearance and Odor:SOLVENT ODOR,LIQUID,SOME COLOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL CAN CAUSE REACTION
Hazardous Decomposition Products:SIO*2,CO*2 & TRACES OF INCOMPLETELY
BURNED CARBON PRODUCTS
* Disposal Considerations *
Waste Disposal Methods:ALL LOCAL,STATE, AND FEDERAL HEALTH & POLLUTION
REGULATIONS BE REVIEWED TO DETERMINE DISPOSAL PROCEDURES.CONTACT
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE A NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN.
Ventilation:MATERIAL SHOULD BE HANDLED OR TRANSFERRED IN AN APPROVED
FUME HOOD OR WITH ADEQUATE VENTILATION.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. DO NOT TAKE
INTERNALLY.
Supplemental Safety and Health
DESCRIBED UNDER DISP. COMPLY WITH FED, STATE AND LOC REGS ON
CON T.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:MAGNESIUM CHLORIDE, HEXAHYDRATE; (MAGNESIUM CHLORIDE)
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION CAN IRRITATE GI TRACT
CAUSING NAUSEA, VOMITING, DIARRHEA. MAY BE IRRITATING ON CONTACT
WITH SKIN, EYES OR MUCOUS MEMBRANES. TESTS ON LABORATORY ANIMALS
INDICATE MATERIAL MAY PRODUCE ADVERSE MUTAGENIC EFFECTS. MAY BE
HARMFUL IF SWALLOWED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:DATA NOT AVAILABLE.
* First Aid Measures *
First Aid:GET MEDICAL ASSISTANCE FOR ALL CASES OF OVEREXPOSURE.
SKIN:WASH THOROUGHLY WITH SOAP AND WATER. EYES:IMMEDIATELY FLUSH
FRESH AIR; GI VE ARTIFICIAL RESPIRATION IF BREATHING HAS STOPPED.
INGESTION:IF CONSCIOUS, DRINK WATER AND INDUCE VOMITING IMMEDIATELY
AS DIRECTED BY MEDICAL PERS. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCON PERSON.
* Fire Fighting Measures *
Flash Point:NONCOMBUSTIBLE
Extinguishing Media:USE ANY SUITABLE FOR ADJACENT MATERIALS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:PRODUCES TOXIC FUMES ON THERMAL
DECOMPOSITION.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE AREA OF ALL UNNEC PERS. WEAR SUITABLE
PROT EQUIP LISTED UNDER CTL MEASURES. ELIM ANY IGNIT SOURCES UNTIL
AREA IS DETERM TO BE FREE FROM EXPLO/FIRE HAZS. CNTN RELS & ELIM
ITS SOURCE, IF THIS C AN BE DONE W/OUT RISK. TAKE UP & (SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED. STORE IN COOL,
DRY AREA AWAY FROM HEAT & ACIDS. DO NOT BREATHE DUST. DO NOT GET IN
EYES, ON SKIN OR ON CLOTHING.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
Solubility in Water:SOLUBLE
Appearance and Odor:WHITE CRYSTALS OR FLAKES.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:EXTREME HEAT.
Hazardous Decomposition Products:MAGNESIUM OXYCHLORIDE, CL-.
* Disposal Considerations *
Waste Disposal Methods:MATERIAL DOES NOT HAVE AN EPA WASTE NUMBER AND
IS NOT LISTED WASTE. HOWEVER CONSULTATION W/PERMITTED WASTE DISP
SITE (TSD) SHOULD BE ACCOMPLISHED. ALWAYS CONT PERMITTED TSD TO
ASSURE COMPLIANCE W/ALL CURRENT LOC, STATE & FED REGS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:AN APPROPRIATE NIOSH-APPROVED RESPIRATOR FOR
ORGANIC VAPOR SHOULD BE WORN IF NEEDED.
NEC TO CONTROL VAPOR.MAINTAIN AIR CONC BELOW IRRIT LEVELS.
Other Protective Equipment:AN EYE BATH AND WASHING FACILITIES SHOULD BE
AVAILABLE.
Work Hygienic Practices:GOOD INDUSTRIAL HYGIENE-PREVENT EYE
CONTACT,MINIMIZE SKIN CONTACT & INHAL OF VAPORS.WASH CONTAM
CLOTHING BEFORE REUSE.
Supplemental Safety and Health
* Product Identification *
Product ID:EKTASOLVE PM ACETATE,STABILIZED
* Composition/Information on Ingredients *
Ingred Name:1-METHOXY-2-PROPANOL ACETATE (PROPYLENE GLYCOL MONOMETHYL
ETHER ACETATE)
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:STABILIZERS
Fraction by Wt: 0.5%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS AND SYMPTOMS OF
OVEREXPOSURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:NO SPECIFIC HAZARD KNOWN.ANY MATERIAL
GOTTEN INTO THE EYE MAY BE IRRITATING.SKIN:NO SPECIFIC HAZARD
KNOWN.INGESTION:CLASSIFIED AS PRACTICALLY NONTOXIC BY SINGLE ORAL
DOSE TESTING IN ANIMALS.INHAL ATION:NO SPECIFIC HAZARD KNOWN.
Medical Cond Aggravated by Exposure:N/K
* First Aid Measures *
SYMPTOMS PERSIST.SKIN:FLUSH W/ PLENTY OF WATER.GET MED ATTN IF
SYMPTOMS PERSIST.INGEST:IF CONSCIOUS,INDUCE VOMITING IMMED BY
GIVING TWO GLASSE S OF WATER & STICKING FINGER DOWN THROAT.GET MED
ATTN IMMED.NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON.INHAL:REMOVE FROM EXPOSURE,TREAT SYMPTOMATICALLY,GET MED
ATTN IF SYMPTOMS PERSIST.
* Fire Fighting Measures *
Flash Point Method:SCC
Lower Limits:SEE SUPP
Upper Limits:SEE SUPP
Extinguishing Media:USE CARBON DIOXIDE,ALCOHOL FOAM,DRY CHEMICAL,WATER
SPRAY.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .PREVENT CONTACT WITH SKIN AND EYES.USE WATER SPRAY TO
KEEP FIRE-EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:NONE.HAZ DECOMP PROD:COMBUSTION WILL
PRODUCE CARBON DIOXIDE AND PROBABLY CARBON MONOXIDE.AUTOIGNITION
* Accidental Release Measures *
Spill Release Procedures:ELIM ALL IGNIT SOURCES.COLLECT SMALL SPILLS W/
ABSORB MATLS.FOR LARGE SPILLS,FLUSH AREA W/ WATER SPRAY.PVNT RUNOFF
FROM ENTERING DRAINS,SEWERS,STREAMS.IF DILUTED W/ LARGE AMT OF
WATER,A SMALL AMT RELE ASED IS NOT EXPECTED TO HAVE SIGNIFICANT
IMPACT.
Neutralizing Agent:N/K
*Handling and Storage *
Handling and Storage Precautions:COMBUSTIBLE LIQUID.KEEP AWAY FROM HEAT
& FLAME.EMPTIED PACKAGES RETAIN PRODUCT RESIDUE,FOLLOW LABEL
WARNINGS EVEN AFTER PACKAGE IS EMPTIED.
Other Precautions:N/K
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:3.7 MMHG
Appearance and Odor:COLORLESS LIQUID WITH SWEET,ETHER-LIKE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS CAN CAUSE A VIGOROUS REACTION.
Stability Condition to Avoid:MATERIAL MAY FORM POTENTIALLY UNSTABLE
PEROXIDES IF THE STABILIZER IS DEPLETED.
Hazardous Decomposition Products:COMBUSTION WILL PRODUCE CO*2 &
PROBABLY CO.MAY FORM POTENTIALLY UNSTABLE PEROXIDE IF STABILIZER IS
DEPLETED.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .INCINERATE.
| 1 | eyes_protection_mandatory |
Control Measures
*
Proprietary Ind: Y
*
Contractor Summary
*
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: ACUTE: INHAL: IRRIT OF RESP TRACT. PRLNGD INHAL MAY LEAD
TO MUC MEMB IRRIT, FATG, DROW, DIZZ &/OR LT HEAD, HDCH, UNCOORD, NAUS,
VOMIT, DIARR, COUGH, DFCLTY W/SPEECH, CNS DEPRESS, METALLIC TASTE, ANEST H
EFT/NARCOS, FEVER & CHILLS, DEHYDRATION, PULM EDEMA, LOSS OF
CONSCIOUSNESS, ASPHY, DEATH. SKIN CONT: (EFTS OF OVEREXP)
Signs And Symptions Of Overexposure: HLTH HAZ: IRRIT. PRLNG/RPTD CONT CAN CAUSE
DERM, DEFAT. EYE: IRRIT. PRLNGD/RPTD CONT CAN CAUSE CONJ, BLURRED VISION,
TEARING, REDNESS. INGEST: MAY CAUSE LUNG INFLAMM & DMG DUE TO ASPIR OF
MATL INTO LU NGS, MOUTH & THROAT IRRIT, MUC MEMB IRRIT, FATG, DROW, DIZZ
&/OR LT HEAD, HDCH, UNCOORD, NAUS, VOMIT, DIARR,
Medical Cond Aggravated By Exposure: EYE, SKIN, RESPIRATORY DISORDERS, LUNG
DISORDERS, ASTHMA-LIKE CONDITIONS.
First Aid: INHAL: REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
GET EMER MED ATTN. HAVE TRAINED PERSON GIVE OXYG IF NEC. GET MED HELP FOR ANY
BRTHG DFCLTY. SKIN: FLUSH W/WATER. THEN WASH THORO W/SOAP & WATER.
REMOVE CONTAMD CLTHG. WASH CONTAMD CLTHG BEFORE RE-USE. EYE: FLUSH IMMED W/LG
PERSIST, OBTAIN MED TREATMENT.
*
Handling and Disposal
*
Spill Release Procedures: ELIM IGNIT. VENT AREA. COLLECT W/ABSORB MATLS. PLACE
COLLECTED MATL IN PROPER CNTNR. CNTNS CHEM THAT IS TOXIC TO FISH. LG
SPILLS-SHUT OFF LEAK IF SAFE TO DO SO. DIKE & CNTN SPILL. PUMP TO
STOR/SALVAGEVESSELS. FOR MORE SPECIFIC INFO CONT NECH (FP N).
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH ALL APPLICABLE FEDERAL,
STATE, AND LOCAL REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
& OPEN FLAME. KEEP AWAY FROM DIRECT SUNLIGHT, HEAT & ALL SOURCES OF
IGNIT. USE ONLY W/ADEQ VENT.
Other Precautions: DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN. AVOID
CONT W/SKIN & EYES, & BRTHG OF VAPS.KEEP CNTNRS TIGHTLY CLSD &
UPRIGHT WHEN NOT IN USE. FOR MORE SPECIFIC INFORMATION CONTACT NEHC (FP N).
*
Fire and Explosion Hazard Information
*
Extinguishing Media: DRY CHEMICAL OR FOAM WATER FOG. CARBON DIOXIDE.
Fire Fighting Procedures: NIOSH APPROVED SCBA & FULL PROTECTIVE EQUIPMENT
(FP N). WATER MAY BE USED TO COOL & PROTECT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard: CLSD CNTNRS MAY EXPLODE WHEN EXPOS TO EXTREME
HEAT/FIRE. VAPS ARE HVR/AIR & MAY TRAVEL LONG DIST TO SOURCE OF IGNIT
& FLASH BACK. VAPS CAN FORM EXPLO (SUPDAT)
*
*
Respiratory Protection: CTL ENVIRONMENTAL CONCS BELOW APPLIC STDS. WHERE RESP
Ventilation: PROVIDE DILUTION VENT/LOCAL EXHAUST TO PVNT BUILD-UP OF VAPORS.
USE EXPLOSION-PROOF EQUIPMENT.
Other Protective Equipment: ANIS APPRVD EYE WASH & DELUGE SHOWER (FP N).
IMPERVIOUS CLOTHING, FACE SHIELD, APRON, BOOTS.
Work Hygienic Practices: WASH HANDS THORO AFTER HANDLING, ESPECIALLY BEFORE
EATING OR SMOKING.
Supplemental Safety and Health: USERS OF "L" VERSION OF SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). MFR TRADE NAME/PART NO: PURPOSE TANK &
STRUCTURAL PRIMER. EXPLO HAZ: MIXTURES IN AIR @ ELEVATED TEMPS. CLSD CNTNRS
MAY B URST IF EXPOS TO EXTREME HEAT/FIRE. MAYDECOMPOSE UNDER FIRE CNDTNS
EMITTING IRRITANT AND/OR TOXIC GASES.
*
Physical/Chemical Properties
*
Evaporation Rate & Reference: NOT KNOWN
Solubility in Water: NOT KNOWN
Appearance and Odor: WHITE.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: ELEVATED TEMPERATURES, CONTACT WITH OXIDIZING
AGENT, SPARKS, OPEN FLAME.
Materials To Avoid: OXIDIZERS, ACIDS, BASES, AMINES, NITRIC ACID, MINERAL
ACIDS.
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE, ACRID FUMES,
OXIDES OF PHOSPHOROUS, ALDEHYDES, TOXIC GASES, SMOKE AND SOOT.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Assigned IND: Y
Company Name: ICI DULUX/DEVOE COATINGS
Label Required IND: Y
Status Code: C
Origination
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Severe
Contact Hazard: Slight
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUST. ACUTE: INHAL: IRRIT. MUC MEMB IRRIT, FATG,
DROW, DIZZ &/OR LT HEAD, HDCH, UNCOORD, NAUS, VOMIT, DIARR, COUGH, DFCLTY
W/SPEECH, CNS DEPRESS, METALLIC TASTE, ANESTH EFT/NARCOS, FEVER & CHILLS,
DEHYDRATION, PULM EDEMA, LOSS OF CONSCIOUSNESS, ASPHY, DEATH. SKIN: IRRIT,
DERM, DEFAT. EYE: IRRIT, CONJ, BLURRED VISION, TEARING, REDNESS. INGEST: LUNG
INFLAMM, ASPIR HAZ, IRRIT, FATG, DROW, DIZZ, LT HEAD, HDCH, UNCOORD, NAUS,
VOMIT, DIARR, GI DISTURB, ABDOM PAIN, CNS DEPRESS, ANESTH, NARCOS, CONVLS,
LOSS OF CONSCIOUSNESS. LIVER & KIDNEY DMG. CHRONIC CANCER HAZ. CNTNS
SILICA, CRYSTALLINE QUARTZ W HICH IS LISTED AS HUMAN LUNG CARCIN (FP N).
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NON REQUIRED UNDER NORMAL CONDITIONS. IF HIGH
VAPOR OR MIST PRESENT, USE NIOSH-APPROVED RESPIRATOR FOR ORGANIC
VAPORS AND MISTS.
Ventilation:MECHANICAL (GENERAL AND/OR LOCAL EXHAUST, EXPLOSION-PROOF)
VENTILATION
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
THAT THEY DISTRIBUTE THE 3M PRODUCT,BLITZ SURGICAL CLEANER.
* Product Identification *
Product ID:BLITZ SURGICAL INSTRUMENT CLEANER AND LUBRI
* Composition/Information on Ingredients *
III)
Other REC Limits:NONE SPECIFIED
Ozone Depleting Chemical:1
Ingred Name:MINERAL OIL/SOLVENT-DEWAXED HEAVY PARAFINIC PETROLEUM
DISTILLATES
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 AS OIL MIST
ACGIH TLV:5 MG/M3 AS OIL MIST
Ingred Name:CARBON DIOXIDE
Fraction by Wt: 2.6%
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:MILD IRRITATION,REDNESS,SWELLING,
PAIN & TEARING.SKIN:PROLONGED/REPEATED CONTACT CAN CAUSE MILD
IRRITATION, REDNESS,SWELLING & ITCHING.INHALED:CAN CAUSE CNS
DEPRESSION,HEADACHE, DIZZINESS,DROWSINE SS &
UNCONSCIOUSNESS.ORAL:ASPIRATION PNEUMONITIS, COUGHING,WHEEZING &
MAY BE DEATH.CHRONIC-MAY CAUSE LIVER,LUNG DAMAGE
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of Overexposure:MILD EYE IRRITATION, REDNESS, SWELLING, PAIN &
TEARING. PROLONGED/REPEATED SKIN CONTACT CAN CAUSE MILD IRRITATION,
REDNESS, SWELLING & ITCHING. INHALATION CAN CAUSE CNS DEPRESSION,
HEADACHE, DIZZINESS , DROWSINESS & UNCONSCIOUSNESS. ASPIRATION
PNEUMONITIS, COUGHING & WHEEZING IF INGESTED. MAY BE FATAL.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS OR IMPAIRED LIVER, KIDNEY OR RESPIRATORY FUNCTION MAY BE
MORE SUSCEPTIBLE TO THE EFFECTS OF THE SUBSTANCE.
* First Aid Measures *
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. SKIN:WASH SKIN
EYELIDS OPEN. INHALED:REMOVE TO FRESH AIR & PROVIDE OXYGEN/CPR IF
NEEDED. ORAL :DO NOT INDUCE VOMITING. GET IMMEDIATE MEDICAL
ATTENTION. IF CONSCIOUS, DRINK TWO GLASSES OF WATER.
* Fire Fighting Measures *
Flash Point:AEROSOL
Lower Limits:0.6
Upper Limits:7
Extinguishing Media:CO2, FOAM/DRY CHEMICAL. WATER SPRAY MAY BE USED TO
KEEP FIRE EXPOSED CONTAINERS COOL & FLUSH SPILLS AWAY.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS IN + PRESSURE MODE.
COOL FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:HYDROGEN CHLORIDE, HYDROGEN FLUORIDE AND
PHOSGENE
* Accidental Release Measures *
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENTS. VENTILATE AREA.
STOP LEAK. SOAK UP SPILLS WITH CLAY/SAND. TRANSFER TO PROPER
CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE
*Handling and Storage *
Handling and Storage Precautions:STORAGE- STORE IN COOL PLACE. KEEP
AWAY FROM HEAT, FLAME & STRONG OXIDANTS.
Other Precautions:CAUTION! PRESSURIZED CONTAINER. EMPTY CONTAINER MAY
CONTAIN PRODUCT RESIDUE WHICH COULD INCLUDE FLAMMABLE/EXPLOSIVE
VAPORS. DO NOT WELD, HEAT OR DRILL CONTAINER. RESIDUE MAY IGNITE
WITH EXPLOSIVE VIOL ENCE IF HEATED SUFFICIENTLY.
* Physical/Chemical Properties *
HCC:V2
Vapor Pres:0.1 - 5.6
Vapor Density:>1
Evaporation Rate & Reference:>1 (ETHER = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIQUID, AMBER COLOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:HEAT, FIRE
Hazardous Decomposition Products:HYDROGEN CHLORIDE, HYDROGEN FLUORIDE
AND PHOSGENE
* Disposal Considerations *
Waste Disposal Methods:INCINERATE IN AN INDUSTRIAL OR COMMERCIAL
FACILITY. DO NOT PUNCTURE OR BURN CANS IN A HOUSEHOLD INCINERATOR.
COMBUSTION PRODUCT WILL INCLUDE HF AND HCL. OBSERVE ALL APPLICABLE
LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NO RESPIRATORY PROTECTION SHOULD BE NEEDED.
Ventilation:NONE SHOULD BE NEEDED
Other Protective Equipment:AVOID CONTACT BY USING IMPERVIOUS PROTECTIVE
CLOTHING, SUCH AS APRONS, BOOTS.
Work Hygienic Practices:WASH IMMEDIATELY UPON ANY DETECTABLE CONTACT.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:JACK L. SHENEBERGER
* Composition/Information on Ingredients *
Ingred Name:CALCIUM CARBONATE
Other REC Limits:NONE SPECIFIED
Ingred Name:AMINOMETHYLPROPANOL
Fraction by Wt: 1%
Other REC Limits:NONE SPECIFIED
Ingred Name:DIETHYLAMINE
Fraction by Wt: 0.4%
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NO KNOWN ADVERSE CHRONIC HEALTH
EFFECTS, BUT UNNECESSARY EXPOSURE TO ANY CHEMICAL SHOULD BE
AVOIDED. THIS PRODUCT, AS WITH ANY CHEMICAL, MAY ENHANCE ALLERGIC
CONDITIONS ON CERTAIN PEOPLE, WE DO NOT KN OW OF ANY MEDICAL
CONDITIONS THAT MIGHTBE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
Effects of Overexposure:EYE: IRRITATION. REDNESS, SWELLING, & SOME
CORNEAL INJURY LASTING SEVERAL DAYS. SKIN: IRRITATION.
REPEATED/PROLONGED CONTACT IRRITATES SERIOUSLY, MAY BURN MILDLY.
CAUSE ALLERGIC SKIN SENSITIZATION. IN HALATION IRRITATES RESP &
EYES. INGEST:LARGE AMTS INJURE SLIGHTLY.
* First Aid Measures *
ATTENTION. SKIN: WIPE OFF THOROUGHLY & FLUSH WITH PLENTY OF WATER
INHALATION: NO FIRST AID SHOULD BE NEEDED. ORAL: GET MEDICAL
ATTENTION.
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:WATER FOG, CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING SHOULD BE WORN IN FIGHTING FIRES INVOLVING
CHEMICALS.
Unusual Fire/Explosion Hazard:HAZARDOUS NITROGEN OXIDES AND COMPOUNDS
OF IODINE AND SULFUR FORM.
* Accidental Release Measures *
Spill Release Procedures:REMOVE PRODUCT & USE ABSORBENT MATERIAL TO
TAKE CARE OF ANY OIL-LIKE RESIDUES.
*Handling and Storage *
CARE AND CAUTION. KEEP CONTAINER CLOSED.
Other Precautions:NONE
* Physical/Chemical Properties *
HCC:N1
Appearance and Odor:SOME ODOR, PASTE-LIKE, GRAY
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL CAN CAUSE A REACTION.
Stability Condition to Avoid:EXPOSURE TO AIR UNTIL READY TO USE.
PRODUCT CURES.
Hazardous Decomposition Products:NITROGEN OXIDES, METAL OXIDES, SILICON
DIOXIDE, CARBON DIOXIDE, COMPOUNDS OF IODINE & SULFUR, & TRACES OF
CARBON PRODUCT
* Disposal Considerations *
Waste Disposal Methods:ALL LOCAL, STATE & FEDERAL REGULATIONS
CONCERNING HEALTH & POLLUTION BE REVIEWED TO DETERMINE APPROVED
DISPOSAL PROCEDURES. CONTACT DOW CORNING IF THERE ARE ANY DISPOSAL
QUESTIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
* Product Identification *
Preparer's Name:DOD HMIS/DGSC-SSH
* Composition/Information on Ingredients *
Ingred Name:ASBESTOS, CHRYSOTILE
OSHA PEL:0.2 FIBERS/CC
Ingred Name:ASBESTOS & NATURAL/SYNTHETIC RUBBER COMPOSITION
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
*Handling and Storage *
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
* Physical/Chemical Properties *
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
* Disposal Considerations *
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE WITH EFFECTIVE VENTILATION AND WEAR NIOSH
APPROVED FUME RESPIRATOR.
Ventilation:PROVIDE ADEQUATE VENTILATION TO MEET TLV REQUIREMENTS.
LOCAL EXHAUST AND MECHANICAL (GENERAL) VENTILATION ADEQUATE.
FACESHIELD .
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA . RUBBER OR PLASTIC-IMPERVIOUS AND/OR WATER
PROOF.
Work Hygienic Practices:AVOID DIRECT SKIN CONTACT WITH KOH. TO REDUCE
ELECTROCUTION RISK ALL ASSOCIATED TOOLS SHOULD BE INSULATED.
Supplemental Safety and Health
TRADE NAME/PART #: WITH LEAD AND CADMIUM.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:LEAD MONOXIDE; (LEAD OXIDE)
OSHA PEL:0.2 MG (CD)/M3 DUST
ACGIH TLV:0.1 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:POTASSIUM HYDROXIDE (CERCLA)
OSHA PEL:C 2 MG/M3
ACGIH TLV:C 2 MG/M3
Ingred Name:POLYSULFONE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHYLENE, TETRAFLUORO-, POLYMER; (TEFLON (TAB INSULATORS))
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC: CONTACT W/CAUSTIC
LIQUID MAY CAUSE SERIOUS BURNS TO HUMAN TISSUE. OVEREXPOSURE OF
CADMIUM OXIDE MAY CAUSE IRRITATION OF NOSE & THROAT. DELAYED
REACTION OF COUGHING, CHEST PAIN, SWEATING , CHILLS, SHORTNESS OF
BREATH & WEAKNESS MAY DEVELOP. IN SEVERE CASES, DEATH MAY OCCUR.
LEAD OXIDE INGEST MAY CAUSE NAUSEA, VOMITING, HEADACHE, DIZZINESS,
GI IRRITATION. CHRONIC EFFECTS RESULTING FROM LOW LEVEL EXPOSURE
TO LEAD COMPONENTS MAY INCLUDE ANEMIA, KIDNEY DAMAGE, IMPAIRED
EYESIGHT & LEAD BUILD-UP IN CNS (PARTICULARLY BRAIN). LEAD APPEARS
ON NAVY LIST OF CHEMICAL REPRODUCTIVE HAZARDS. SEE K (EFTS OF
OVEREXP)
Explanation of Carcinogenicity:CADMIUM OXIDE: IARC MONOGRAPHS ON
Effects of Overexposure:HEALTH HAZARDS: CONSULTATION FROM APPROPRIATE
HEALTH PROFESSIONALS CONCERNING LATEST HAZARD LIST INFORMATION AND
SAFE HANDLING AND EXPOSURE INFORMATION .
Medical Cond Aggravated by Exposure:PREEXISTING KIDNEY, RESPIRATORY,
PROSTATE AND BLOOD SYSTEMS MAY BE AGGRAVATED.
* First Aid Measures *
First Aid:INHALATION: REMOVE FROM EXPOSURE. GET MEDICAL ATTENTION.
SKIN: REMOVE CONTAMINATED CLOTHING AND WASH WITH LARGE AMOUNTS OF
WATER. GET MEDICAL ATTENTION. EYES: FLUSH WITH WATER FOR AT LEAST
INGESTION: DRINK PLENTY OF WATER AND FRUIT JUICE. DO NOT INDUCE
VOMITING. GET PROMPT MEDICAL ATTENTION.
* Fire Fighting Measures *
Extinguishing Media:USE EXTINGUISHING MEDIA FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:FIRE MAY LIBERATE TOXIC LEAD & CADMIUM
FUMES AS WELL AS HAZARDOUS FLUORINE COMPONENTS, INCOMPLETE BURNING
OF POLYSULFONE MAY RELEASE CARBON DIOXIDE; THE CONTACT OF KOH (THE
ELECTROLYTE) WITH METALS CA N RELEASE HYDROGEN GAS. ACTIVATED CELLS
OR BATTERY MAY BE FIRE HAZARD IF EXTERNALLY SHORTED.
* Accidental Release Measures *
Spill Release Procedures:PROT CLTHG & EQUIP MUST BE WORN BY CLEAN-UP
PERS. CONTAIN SPILLAGE/LEAKAGE IN SUITABLE CONTR/CONTAIN IN HOLDING
AREA. DO NOT ALLOW DRAINAGE TO SEWER, STREAMS/STORM CONDUITS.
REMOVE SOLIDS W/CLEAN SHOV EL & VACUUM LIQ (SUITABLE ABSORB MAY
BEUSED).
Neutralizing Agent:NEUTRALIZE W/WEAK ACID SOLUTION (VINEGAR, BORIC
ACID) & FLUSH W/WATER.
*Handling and Storage *
Handling and Storage Precautions:DRY BATTERIES TO BE STORED AT
SHOULD BE DISCHARGED AS PER MANUFACTURER'S OPERATING PROCEDURES AND
* Physical/Chemical Properties *
Appearance and Odor:CELL-A RECTANGULAR PLASTIC CUBE OF AMBER COLOR WITH
MULTIPLE ELECTRODES VISIBLE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
HYDROGEN PEROXIDE, AMINES, REDUCING AGENTS, MOLTEN ALKALI METALS,
ALUMINUM AND TIN (KOH ONLY).
Stability Condition to Avoid:AVOID STORAGE TEMPERATURES GREATER THAN
BE EVOLVED; KOH & METALS MAY LIBERATE H*2 GAS, HYDROGEN FLUORIDE
MAY BE FORMED WHEN TEFLON BURNS
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL LAWS AND REGULATIONS. SPENT (USED) BATTERIES SHOULD BE
COLLECTED FOR PRECIOUS METALS RECLAMATION.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:ALWAYS USE A NIOSH-APPROVED RESPIRATOR WHEN
Ventilation:USE PROCESS ENCLOSURE, LOCAL EXHAUST VENTILATION/OTHER
ENGINEERING CONTROLS TO CONTROL AIRBORNE LEVELS.
Other Protective Equipment:PROTECTIVE CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
INCOMPATIBILITIES: ACIDS/ACIDIC
ANHYDRIDE/ALCOHOLS/ANILINE/FORMALDEHYDE/ANTIMONY III
COMPOUNDS/BISMUTH/CELLULOSE/CHARCOAL/DIBUTYL SULFOXIDE/DIETHYL
ETHER/DIMETHYL SULFOXIDE/FLUORINE/GLYCERINE/LEAD OXI DE/GLYCOL
ETHERS/GLYCOLS/HYDRIODIC
ACID/HYDROGEN/HYPOPHOSPHITES/KETONES/METHYL ALCOHOL/NITROGEN
IODIDE/NITROSOPHENOL.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:WATER
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: CORROSIVE. CAUSES BURNS.
INGESTION: GASTROINTESTINAL BURNS. INHALATION: SEVERE IRRITATION OF
THE RESPIRATORY TRACT W/SORE THROAT & DELAYED LUNG EDEMA.
PROLONGED/REPEATED EXPOSURE MAY CAUSE TEETH EROSION, PERFORATION
OF THE NASALSEPTUM, CONJUNCTIVITIS, DERMATITIS, POSSIBLE SKIN
DESTRUCTION/ULCERATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, BURNS, SORE THROAT, COUGHING,
SHORTNESS OF BREATH, NOSEBLEEDS, NASAL CONGESTION, CHEST PAIN,
BRONCHITIS
* First Aid Measures *
DON'T INDUCE VOMITING. IF CONSCIOUS & ALERT, GIVE 2-4 CUPFULS OF
MILK/WA TER. INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF
NECESSARY. OBTAIN MEDICAL ATTENTION IN ALL CASES. TREAT
SYMPTOMATICALLY & SUPPORTIVELY.
* Fire Fighting Measures *
Extinguishing Media:USE WATER ONLY.
Fire Fighting Procedures:USE APPROPRIATE PROTECTIVE CLOTHING TO PREVENT
CONTACT W/SKIN/EYES. WEAR SELF CONTAINED BREATHING APPARATUS TO
PREVENT CONTACT W/THERMAL DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:CONTACT W/COMBUSTIBLE MATERIALS MAY CAUSE
A FIRE. THIS MATERIAL IS A STRONGLY ACIDIC, POWERFUL OXIDIZING
SUBSTANCE. ANHYDROUS FORM OF THIS MATERIAL IS EXPLOSIVE
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PROTECTIVE EQUIPMENT. COVER W/SAND,
DRY LIME/SODA ASH & PLACE IN A CLOSED CONTAINER FOR DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:DON'T STORE NEAR COMBUSTIBLE
MATERIALS. STORE IN A COOL, DRY PLACE. STORE IN A TIGHTLY CLOSED
CONTAINER. USE W/ADEQUATE VENTILATION.
Other Precautions:AVOID CONTACT W/CLOTHING. DON'T GET ON SKIN/IN EYES.
DON'T INGEST/INHALE.
* Physical/Chemical Properties *
Spec Gravity:1.7
pH:<7
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR COLORLESS LIQUID W/NO ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE/COMBUSTIBLE MATERIALS, ORGANIC MATERIALS, REDUCING AGENTS,
ALKALINE MATERIALS, DEHYDRATING AGENTS, (SUPP)
Hazardous Decomposition Products:CHLORINE DIOXIDE
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:ALWAYS USE A NIOSH-APPROVED RESPIRATOR WHEN
Ventilation:USE ADEQUATE VENTILATION TO KEEP AIRBORNE CONCENTRATIONS
LOW.
Other Protective Equipment:WEAR APPROPRIATE PROTECTIVE CLOTHNG.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
* Product Identification *
CAGE:0B0Y1
CAGE:0B0Y1
* Composition/Information on Ingredients *
Ingred Name:WATER
Fraction by Wt: BALANCE
Ingred Name:SURFACTANT
< Wt:1.
Ingred Name:SODIUM AZIDE
< Wt:1.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:UNKNOWN Ingestion:YES
Health Hazards Acute and Chronic:EYES/SKIN: MAY CAUSE IRRITATION.
INGESTION: IRRITATION OF THE DIGESTIVE TRACT. INHALATION:
RESPIRATORY TRACT IRRITANT.
Effects of Overexposure:IRRITATION
* First Aid Measures *
ALERT, GIVE 2-4 CUPFULS OF MILK/WATER. NEVER GIVE ANYTHING BY MOUTH
IF UNCONSCIOU S. INHALATION: REMOVE TO FRESH AIR IMMEDIATELY. GIVE
CPR/OXYGEN IF NECESSARY. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:USE AGENT MOST APPROPRIATE TO EXTINGUISH FIRE.
Fire Fighting Procedures:WEAR A SELF CONTAINED BREATHING APPARATUS IN
PRESSURE-DEMAND, MSHA/NIOSH APPROVED & FULL PROTECTIVE GEAR.
* Accidental Release Measures *
Spill Release Procedures:ABSORB W/INERT MATERIAL, DRY SAND/EARTH, THEN
PLACE INTO A CHEMICAL WASTE CONTAINER. USE PROPER PERSONAL
PROTECTIVE EQUIPMENT.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL-VENTILATED
AREA AWAY FROM INCOMPATIBLE SUBSTANCES. USE W/ADEQUATE VENTILATION.
Other Precautions:AVOID CONTACT W/EYES, SKIN & CLOTHING. AVOID
INGESTION & INHALATION.
* Physical/Chemical Properties *
Appearance and Odor:CLEAR LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACIDS, AMMONIUM CHLORIDE + TRICHLOROACETONITRILE, BARIUM CARBONATE,
BROMINE, CARBON DISULFIDE, CARBONYL DICHLORIDE (PHOSGENE), CYANURIC
CHLORIDE, CHROMYL CHLORIDE, 2,5-DINITRO-3-METHYLBENZOIC ACID +
OLEUM, HEAVY METALS, SUL
Hazardous Decomposition Products:SODIUM AZIDE: WILL REACT W/LEAD,
SILVER, MERCURY TO FORM SHOCK SENSITIVE & EXPLOSIVE METAL AZIDES.
NITROGEN OXIDES, CO, CO2, HYDRAZOIC ACID.
* Toxicological Information*
Toxicological Information:NO CHRONIC EFFECTS/OVEREXPOSURE ARE CURRENTLY
KNOWN. NONE OF THE COMPONENTS ARE LISTED AS A CARCINOGEN/SUSPECTED
CARCINOGEN.
* Ecological Information *
Ecological:NO INFORMATION AVAILABLE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
* Regulatory Information *
SARA Title III Information:SARA REPORTABLE QUANTITIES (RQ): CAS#
CHRONIC, REACTIVE.
State Regulatory Information:STATE RIGHT TO KNOW: SODIUM AZIDE CAN BE
FOUND ON THE FOLLOWING STATE RIGHT-TO-KNOW LISTS: CALIFORNIA, NEW
JERSEY, FLORIDA, PENNSYLVANIA, MINNESOTA, MASSACHUSETTS.
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Other Protective Equipment:LAB COAT
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:PHENOL RED, PHENOLSULFONEPTHALEIN
Fraction by Wt: <1%
Ingred Name:SODIUM HYDROXIDE, CAUSTIC SODA, LYE
Fraction by Wt: <1%
Other REC Limits:2MG/M3 CEILING NIOSH
OSHA PEL:2 MG/CUM
ACGIH TLV:2 MG/CUM CEILING
Ingred Name:WATER
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: IRRITATION.
CONTACT MAY CAUSE STAINING. INGESTION: GASTROINTESTINAL IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, STAINING OF SKIN.
Medical Cond Aggravated by Exposure:EYE & SKIN CONDITIONS.
* First Aid Measures *
THOROUGHLY W/SOAP & WATER. INGESTION: GIVE PLENTY OF WATER. INDUCE
VOMITING UNDER DIRECTION OF PHYSICIAN. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
* Fire Fighting Measures *
Fire Fighting Procedures:WEAR SELF CONTAINED POSITIVE PRESSURE
BREATHING APPARATUS & FULL PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:MAY EMIT TOXIC FUMES.
* Accidental Release Measures *
Spill Release Procedures:ABSORB W/VERMICULITE/OTHER INERT MATERIAL.
CONTAINERIZE FOR LATER DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY AREA. AVOID
DIRECT SUNLIGHT.
Other Precautions:AVOID CONTACT W/EYES, SKIN & CLOTHING. AVOID
BREATHING CHEMICAL.
* Physical/Chemical Properties *
Vapor Density:0.6
Spec Gravity:1
pH:7.6
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, RED ORANGE LIQUID W/SULFIDIC ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:EXTREME HEAT, TEMPS, DIRECT SUNLIGHT.
Hazardous Decomposition Products:CARBON OXIDES, SULFUR OXIDES
* Disposal Considerations *
Waste Disposal Methods:INCINERATION/OTHER METHOD IN ACCORDANCE W/LOCAL,
STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT REQUIRED
Ventilation:LOCAL EXHAUST: AIR. MECHANICAL: FAN.
Other Protective Equipment:APPROPRIATE TO AVOID PROLONGED CONTACT.
Work Hygienic Practices:WASH HANDS BEFORE EATING/SMOKING/DRINKING AFTER
HANDLING THIS PRODUCT. TRAIN EMPLOYEES IN SAFE HANDLING OF THIS
PRODUCT.
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE ESTABLISHED. POSSIBLE SKIN
IRRITATION AFTER PROLONGED CONTACT, WITH RESULTING DERMITITIS. NOT
CONSIDERED TO BE A PRIMARY SKIN IRRITANT.
Effects of Overexposure:SKIN OR EYE IRRITANT.
* First Aid Measures *
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER, CONSULT PHYSICIAN.
SKIN: WASH WITH SOAP AND WATER. INGESTION: INDUCE VOMITING, CONSULT
PHYSICIAN.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:DRY CHEMICAL, FOAM, CARBON DIOXIDE, WATER.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:SCOOP UP AND TRANSFER TO CONTAINER FOR
REACTION WITH CURING AGENT. CLEAN UP RESIDUE WITH 1,1,1
TRICHLOROETHANE THEN WITH SOAP AND WATER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL DRY PLACE AWAY FROM
STRONG ACIDS
* Physical/Chemical Properties *
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:LIQ@RMTEMP
Vapor Pres:NIL
Vapor Density:NIL
Evaporation Rate & Reference:NIL (BU AC=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE PASTE, POLYSULFIDE ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZING AGENTS, AND STRONG ACIDS.
Stability Condition to Avoid:OPEN FLAME.
Hazardous Decomposition Products:H2S, CO, CO2, SO2, SMOKE.
* Disposal Considerations *
Waste Disposal Methods:REACT WITH CURING AGENT AND DISPOSE AS SOLID
WASTE PER LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:HIGH LEVELS - NIOSH/MSHA APPROVED SUPPLIED-AIR
RESPIRATOR W/FULL FACEPIECE. NIOSH/MSHA APPROVED SELF-CONTAINED
BREATHING APPARATUS W/FULL FACEPIECE.
Ventilation:PROVIDE LOCAL EXHAUST OR GENERAL DILUTION VENTILATION
SYSTEM.
Other Protective Equipment:EMPLOYEE MUST WEAR APPROP PROT CLTHG & EQUIP
TO PVNT RPTD/PRLNG SKIN CONT W/THIS SUBSTANCE. WHERE THERE IS ANY
(SUPDAT)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC:UPPER & LOWER LIDS, UNTIL NO EVID OF CHEM REMAINS (AT
OTHER PROT EQUIP:POSSIBILITY THAT EMPLOYEE'S EYES MAY BE EXPOS TO
THIS SUBSTANCE, EMPLOYER SHALL PROVIDE EYE-WASH FOUNTAIN W/IN
IMMEDIATE WORK AREA FOR EMERGENCY USE.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:POTASSIUM IODIDE
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:IRRITANT. EXPOSURE TO
SUBSTANCE MAY CAUSE NAUSEA, VOMITING, FEVER, HEADACHE, HYPOTENSION,
WEAKNESS & FATIGUE. SKIN CONTACT:IRRITANT/SENSITIZER. MAY CAUSE
IRRITATION. EYE:IRRITANT. DIRECT C ONTACT MAY CAUSE REDNESS &
IRRITATION. CHRONIC:INHAL:MAY CAUSE MUCOUS MEMBRANE IRRITATION.
SKIN: (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:REPEATED OR PROLONGED CONTACT MAY
CAUSE DERMATITIS. EYE:MAY CAUSE CONJUNCTIVITIS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INGEST:CALL MD IMMED . INHAL:REMOVE FROM EXPOS AREA TO FRESH
AIR IMMED. IF BRTHG HAS STOPPED, GIVE ARTF RESP. KEEP AFFECTED
PERSON WARM & AT REST. GET MED ATTN. SKIN:REMOVE CONTAM CLTHG &
SHOES IMMED. WASH AFFECTED AREA W/SOAP OR MILD DETERGENT & LG AMTS
ATTN IMMED. EYE:WASH IMMED W/LG AMTS OF WATER, OCCAS LIFTING
* Fire Fighting Measures *
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, WATER SPRAY OR FOAM.
FOR LARGER FIRES, USE WATER SPRAY, FOG OR ALCOHOL FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . NO ACUTE HAZARD. MOVE CNTNR FROM FIRE AREA IF POSS.
AVOID BRTHG VAPS/DUSTS; KEEP UPWIND.
Unusual Fire/Explosion Hazard:NEGLIGIBLE FIRE & EXPLOSION HAZARD WHEN
EXPOSED TO HEAT OR FLAME.
* Accidental Release Measures *
Spill Release Procedures:NO SPECIAL PRECAUTIONS INDICATED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID EYE & SKIN CONTACT.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
Spec Gravity:1
pH:NEUT
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS .
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPRVD SCBA OR INDUSTRIAL
CANISTER-TYPE MASK (MFR)
Ventilation:LOCAL-TO KEEP CONC BELOW TLV
Other Protective Equipment:RUBBER BOOTS & APRON
Supplemental Safety and Health
GALLON DRUM
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:CRESOL, ALL ISOMERS (CRESYLIC ACID) (SARA III)
OSHA PEL:S, 5 PPM
Ingred Name:CHROMIUM ION (CR 6+)
Fraction by Wt: <0.2%
OSHA PEL:C, 0.1 MG/M3 (CRO3)
Ingred Name:METHYLENE CHLORIDE(SARA III)
* Hazards Identification *
Effects of Overexposure:SKIN: DRYING.EYE: IRRIT. INHAL: EYE &
RESPIRATORY IRRIT,DIZZ,NAUS,POSSIBLE UNCONSCIOUSNESS
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR,APPLY ARTIF RESP IF NEC,GET
AID.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:CO*2,FOAM
Fire Fighting Procedures:WEAR SELF CONT BRTH APPAR
NO EXPLOSIVE CHARACTERISTICS.
* Accidental Release Measures *
Spill Release Procedures:FLUSH W/ DETERGENT & WATER & MOP DRY.
*Handling and Storage *
SAFETY PRECAUTIONS FOR HANDLING ALKALINE SOLVENT PRODUCTS
Other Precautions:NO SMOKING,FLAME CUTTING,ARC WELDING,OPEN FLAME OR
HOT SURFACES IN AREA OF USE.
* Physical/Chemical Properties *
HCC:T4
Vapor Density:>1
Evaporation Rate & Reference:>1 (NBUAC=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:REDDISH TO RUST COLOR W/CRESYLIC ACID ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:DO NOT LOSE WATER SEAL
Hazardous Decomposition Products:THERMAL DECOMP: CO,OXIDES OF
NITROGEN,SULFUR & PHOSGENE
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IAW FED, STATE & LOCAL CODES.
| 1 | eyes_protection_mandatory |
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.