text
stringlengths 789
11.3k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT NORMALLY REQUIRED.
Work Hygienic Practices:CLEAN UP ANY SPILLS.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:WATER
Ingred Name:2-(2-BUTOXYETHYOXY)-ETHANOL, DIETHYLENE GLYCOL MONOBUTYL
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:PROPRIETARY MIXTURE OF FLUORINATED SURFACTANTS AND
SYNTHETIC DETERGENTS
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: MAY CAUSE IRRITATION.
PRACTICALLY NON-TOXIC ORALLY.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, WATERING EYES, REDDENING OF SKIN.
* First Aid Measures *
First Aid:EYES: FLUSH W/WATER. SKIN: WASH W/SOAP & WATER. INHALATION:
REMOVE TO FRESH AIR. INGESTION: DON'T INDUCE VOMITING. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point:NONE
* Accidental Release Measures *
Spill Release Procedures:COLLECT & WASH RESIDUE TO A WASTEWATER
TREATMENT SYSTEM.
*Handling and Storage *
Handling and Storage Precautions:STORE IN ORIGINAL CONTAINER.
Other Precautions:AVOID SKIN CONTACT.
* Physical/Chemical Properties *
Evaporation Rate & Reference:(BU AC=1): <1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR PALE YELLOW
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
CONCENTRATION IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:AREAS OF POOR VENTILATION-AIR SUPPLIED MASK OR
ORGANIC VAPOR GAS
Ventilation:LOCAL EXHAUST: PREFERRED/MECHANICAL: ACCEPTABLE
Other Protective Equipment:SAFETY SHOWER AND EYE BATH.
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:TOLUENE (SARA III)
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
Ingred Name:LEAD MONOXIDE (LEAD OXIDE YELLOW)
* Hazards Identification *
Effects of Overexposure:IRRITATION OF MUCOUS MEMBRANES OF EYES, NOSE,
THROAT, FATIGUE, NAUSEA. HIGH OVER EXPOSURE-NARCOSIS
* First Aid Measures *
First Aid:SKIN: WIPE OFF IMMEDIATELY. WASH WITH SOAP & WATER. FLUSH
WITH WATER. EYE: WASH OUT WITH LARGE VOLUME OF WATER. CONSULT A
PHYSICIAN. INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL
ASSISTANCE. GIVE AR TIFICIAL RESP, IF NECESSARY.
* Fire Fighting Measures *
Lower Limits:1.2%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:AIR MASK
* Accidental Release Measures *
Spill Release Procedures:EXTINGUISH ALL SPARKS & FLAMES. PROVIDE GOOD
VENTILATION. AVOID BREATHING VAPORS. ALW SOLVENTS TO EVAPORATE OR
COVER WITH EXTINGUISHER FOAM. SCRAPE UP WITH ASTIC SCRAPER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A DRY,COOL,PLACE(APPROX
CONTAINER TIGHTLY CLOSD WHEN NOT IN USE.
Other Precautions:USE WITH ADEQUATE VENTILATION. AVOID SKIN CONTACT.
AVOID PROLONGED OR REPEATED BREATHING OF VAPORS. USE IN AREA FREE
FROM SPKS AND FLAME.
* Physical/Chemical Properties *
HCC:F2
Spec Gravity:1.0
Solubility in Water:SLIGHT
Appearance and Odor:BROWN COLORED LIQUID WITH KETONE ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS
Stability Condition to Avoid:HEAT, SPARKS, FLAME
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
NITROUS OXIDES, AMMONIA
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE &
LOCAL ANTI-POLLUTION REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:NAPHTHENICOIL
Ingred Name:WAX
Ingred Name:METHACRYLATE COPOLYMER
* First Aid Measures *
First Aid:REPART TO DOCTOR
* Fire Fighting Measures *
Extinguishing Media:CARBON DIOXIDE,FOAM
Fire Fighting Procedures:TREAT AS PETROLEUM OIL FIRES
* Accidental Release Measures *
Spill Release Procedures:ALLOW TO COOL,SCRGSE UP EXCESS.WASH AREA WITH
ALKALINE OR EMULSIFIABLE CLEANER
*Handling and Storage *
Handling and Storage Precautions:OPEN FLAMES
* Physical/Chemical Properties *
HCC:N1
Appearance and Odor:AMBER PASTE-OIL/WAX ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
* Disposal Considerations *
Waste Disposal Methods:SAME AS PETROLEUM OIL-WAX
| 1 | eyes_protection_mandatory |
Control Measures
*
Proprietary Ind: Y
*
Contractor Summary
*
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHAL: IRRIT OF RESP TRACT. PRLNG INHAL MAY LEAD TO MUC
MEMB IRRIT, DROW, DIZZ &/OR LT HEAD, HDCH, GI DISTURBS, COUGH, APATHY,
CNS DEPRESS, RESP PROBS, ANESTH EFT/NARCOS, DFCLTY BRTHG, BLOOD ABNORMS,
PNEUMOCONIOSIS, LOSS OF CONSCIOUSNESS. SKIN: IRRIT. PRNG/RPTD CNTCT CAN CAUSE
DERM. SKIN CNTCT MAY (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ: RSLT IN DERMAL ABSORPTION OF
INGREDS WHICH MAY CAUSE GI DISTURBS, APATHY. EYES: IRRIT. INGEST: MAY CAUSE
DIZZ &/OR LT HEAD, HDCH, VOMIT, DIARR, GI DISTURBS, SEV ABDOM PAIN,
APATHY, CNS DEPRE SS, RESP PROBS, INTOXICATION, PULM EDEMA, LOSS OF
CONSCIOUSNESS, ACUTE POISONING, RESP FAILURE, CARD FAILURE, (SUPDAT)
Medical Cond Aggravated By Exposure: INGREDIENTS CONTAINED IN THESE PRODUCTS
HAVE BEEN REPORTED TO AGGRAVATE PREEXISTING EYE, SKIN, RESPIRATORY DISORDERS,
LUNG DISORDERS & KIDNEY DISORDERS.
First Aid: INHAL: REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
GET EMER MED ATTN. HAVE TRAINED PERSON GIVE OXYGEN IF NEC. GET MED HELP FOR
ANY BRTHG DFCTLY. SKIN: WASH OFF QUICKLY W/PLENTY OF WATER, T HEN SOAP &
WATER; REMOVE CONTAMD CLTHG.WASH CONTAMD CLTHG BEFORE REUSE. EYES: FLUSH
OTHER EFTS DEVELOP, OBTAIN MED
*
Handling and Disposal
*
Spill Release Procedures: COMPLY WITH ALL APPLICABLE HEALTH & ENVIRONMENTAL
REGULATIONS. VENTILATE AREA. SPILLS MAY BE COLLECTED WITH ABSORBENT
MATERIALS. COMPLETE PERSONAL PROTECTIVE EQUIPMENT MUST BE USED DURING
CLEANUP.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH ALL APPLICABLE FEDERAL,
STATE AND LOCAL REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
AND OPEN FLAME. KEEP FROM FREEZING. KEEP CONTAINERS TIGHTLY CLOSED AND
UPRIGHT WHEN NOT IN USE.
Other Precautions: USE ONLY W/ADEQ VENT. DO NOT TAKE INTERNALLY. KEEP OUT OF
REACH OF CHILDREN. AVOID CNTCT W/SKIN & EYES & BRTHG OF VAPS. AVOID
CNDTNS WHICH RSLT IN FORM OF INHALABLE PARTICLES SUCH AS SPRAYING/ABRADING
(SANDING) PAINTED SURFS. IF
*
Fire and Explosion Hazard Information
*
Lower Limits: SEE INGS
Extinguishing Media: DRY CHEMICAL OR FOAM.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N). WATER MAY BE USED TO COOL AND PROTECT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard: CLOSED CONTAINERS MAY BURST IF EXPOSED TO
EXTREME HEAT OR FIRE.
*
*
Respiratory Protection: CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW APPLICABLE
STANDARDS. WHERE RESPIRATORY PROTECTION IS REQUIRED, USE ONLY NIOSH/MSHA
Ventilation: PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT BUILD-UP
OF VAPORS.
Other Protective Equipment: EYE WASH, SAFETY SHOWER.
Work Hygienic Practices: WASH HANDS THORO AFTER HANDLING, ESPECIALLY BEFORE
EATING OR SMOKING.
Supplemental Safety and Health: USERS OF "L" VERSION OF SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). EFTS OF OVEREXP: BRAIN DMG, DEATH. ORAL
CONSUMPTION OF PRODS CONTAINING ETHYLENE GLYCOL MAY PRDCE ADVERSE HLTH EFTS;
ING EST LG VOLS MAY RSLT IN KIDNEY DMG &/ORFAILURE. STUDIES W/LAB ANIMALS
SHOW THAT HIGH DOSES OF ETHYLENE GLYCOL,
*
Physical/Chemical Properties
*
Vapor Pres: SEE INGS
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: ELEVATED TEMPERATURES, CONTACT WITH OXIDIZING
AGENT, OPEN FLAME.
Materials To Avoid: OXIDIZERS, ACIDS, METALS, ALCOHOLS.
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Company Name: GLIDDEN CO MEMBER OF ICI WORLD PAINTS
Label Required IND: Y
Status Code: C
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE: INHAL: IRRIT OF RESP TRACT. PRLNG INHAL MAY LEAD
TO MUC MEMB IRRIT, DROW, DIZZ &/OR LT HEAD, HDCH, GI DISTURBS, COUGH,
APATHY, CNS DEPRESS, RESP PROBS, ANESTH EFT/NARCOS, DFCLTY BRTHG, BLOOD AB
NORMS, PNEUMOCONIOSIS, UNCON. SKIN: IRRIT. PRNG/RPTD CNTCT CAN CAUSE DERM.
SKIN CNTCT MAY RESULT IN ABSORPTION CAUSING GI DISTURBS, APATHY. EYE CNTCT:
IRRIT. INGEST: MAY CAUSE DIZZ, LT HEAD, HDCH, VOM IT, DIARR, GI DISTURBS,
ABDOM PAIN, APATHY, CNS DEPRESS, PULM EDEMA, UNCON, POISONING, CARD FAILURE,
BRAIN DMG, DEATH. CHRONIC: CONTAINS SILICA WHICH IS AN INHALATION HAZ CAUSING
SILICOSIS. OVEREXP HA S CAUSED KIDNEY DMG IN LAB ANIMALS.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHEN AIR IS NOT BEING MONITORED, NIOSH/MSHA
APPRVD SUPPLIED AIR RESP MUST BE WORN. WHEN AIR BORN CONC ARE
MONITORED, & EXCEED APPROP TLV FOR ANY ISOCYANATES PRESENT, BUT ARE
Ventilation:PROVIDE ADEQUATE CROSS AIR CIRCULATION. EXHAUST AT POINT OF
USE.
Other Protective Equipment:EYEWASH STATION. IMPERMEABLE APRON OR
GARMENT TO MINIMIZE SKIN CONTACT.
Work Hygienic Practices:WASH HANDS WITH SOAP AND WATER AND USE HAND
CREAM.
Supplemental Safety and Health
RESP PROT:APPROVED AIR PURIFYING ISOCYANATE VAPOR RESPIRATOR IS
REQUIRED. APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR SUITABLE FOR
ORGANIC VAPORS SHOULD BE USED FOR ANY OTHER SOLVENTS OR HAZARDOUS
INGR EDIENTS IF NECESSARY, IF THE ISOCYANATETLV HAS NOT BEEN
REACHED.
* Product Identification *
Preparer's Name:J. PARTINGTON
CAGE:BELZ0
CAGE:BELZ0
* Composition/Information on Ingredients *
Ingred Name:BENZENE, 2,4-DIISOCYANATO-1-METHYL-;(TOLUENE
Fraction by Wt: 1-2%
Ingred Name:PHTHALIC ACID, BIS (2-ETHYLHEXYL) ESTER;(DI(2-ETHYLHEXYL)
PHTHALATE)
Fraction by Wt: 1-5%
Ingred Name:CARBON BLACK
Fraction by Wt: 1-5%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SENSITIZER. ACUTE:SKIN, EYES AND
RESPIRATORY TRACT IRRITANT. CHRONIC:IRRITATION, SENSITIZATION AND
DERMATITIS. TDI LISTED BY NTP AS REASONABLY ANTICIPATED CARCINOGEN.
TDI LISTED BY IARC AS SUSPECT CAR CINOGEN IN LAB ANIMALS.
IDENTIFIED BY ACGIH AS A SUSPECTED OR CONFIRMED HUMAN CARCINOGEN.
Explanation of Carcinogenicity:TOLUENE DIISOCYANATE (2,4):GROUP 2
(NTP), GROUP 2B (IARC);DI(2 ETHYLHEXYL) PHTHALATE IARC GROUP2; NTP
GROUP 2.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PRECLUDE FROM EXPOSURE THOSE
INDIVIDUALS WITH DISEASES OF THE SKIN, SINUSES AND LUNGS.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR AND GIVE ARTIFICIAL RESPIRATION IF
W/SOAP & WATER. REMOVE CONTAM CLTHG. WASH BEFORE REUSE. INGEST:DO
NOT IN DUCE VOMITING. RINSE MOUTH WITH WATER. DRINK LG QUANITITES
OF WATER IMMED. IF INGEST, CALL TAMPA BAY REGIONAL POISON CENTER
* Fire Fighting Measures *
Flash Point Method:SCC
Extinguishing Media:WATER FOG (NOT A DIRECT STREAM OF WATER), FOAM,
ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . USE WATER TO DILUTE SPILLS AND COOL
CONTAINERS. DECOMTAMINATE CLOTHING AFTER USE.
Unusual Fire/Explosion Hazard:DECOMPOSITION AND COMBUSTIBLE PRODUCTS
MAY BE HAZARDOUS.
* Accidental Release Measures *
Spill Release Procedures:USE SAND TO ABSORB SPILLED MATERIAL AND
DISPOSE OF PROPERLY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:PROTECT FROM FREEZING. OVERHEATING MAY
CAUSE CNTNR TO RUPTURE. MUST BE KEPT IN DRY, COOL AND COVERED AREA.
AVOID BREATHING VAPS AND CONTACT W/SKIN.
Other Precautions:EMPTY CONTAINERS RETAIN RESIDUES AND MAY BE
DANGEROUS. DISCARD CONTAMINATED SHOES. CARBON BLACK IS LISTED IN
LEAKS.
* Physical/Chemical Properties *
Vapor Density:HVR/AIR
Solubility in Water:<1%
Appearance and Odor:BLACK VISCOUS LIQUID WITH SLIGHT ODOR.
Percent Volatiles by Volume:0.0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZERS, WATER, ALCOHOL, EPOXIES
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:GASESOUS COMBINATIONS OF CARBON,
HYDROGEN, OXYGEN AND NITROGEN.
* Disposal Considerations *
Waste Disposal Methods:LABEL EMPTY CONTAINERS HAZARDOUS. DISPOSE OF IN
ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
* Product Identification *
Preparer's Name:DOD HMIS/DGSC-SSH
* Composition/Information on Ingredients *
Ingred Name:ASBESTOS, CHRYSOTILE
OSHA PEL:0.2 FIBERS/CC
Ingred Name:ASBESTOS & NICKEL ALLOY COMPOSITION
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
*Handling and Storage *
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
* Physical/Chemical Properties *
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
* Disposal Considerations *
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA/OSHA APPROVED DUST/MIST
EXCEEDED.
Ventilation:LOCAL EXHAUST FOR DRY TUMBLING. MECHANICAL DUST COLLECT
SYSTEM IF DUST GENERATION EXCEEDS THE PEL.
Other Protective Equipment:PROTECTIVE CLOTHING WHICH MINIMIZES SKIN
EXPOSURE TO ABRASIVE FORMS/DUST.
Supplemental Safety and Health
* Product Identification *
Product ID:CERAMIC TUMBLING MEDIA
Preparer's Name:THOMAS J KENNEDY
* Composition/Information on Ingredients *
Ingred Name:CRYSTALLINE-FUSED SILICA, SILICON DIOXIDE, AMORPHOUS QUARTZ
ACGIH TLV:0.1 MG/CUM RESP DUST
Ingred Name:ALUMINUM OXIDE, BAUXITE, ALUMINA, DIALUMINUM TRIOXIDE
Ingred Name:CRYSTALLINE-QUARTZ SILICA, SILICA DUST (SUSPECTED HUMAN
ACGIH TLV:0.1 MG/CUM RESP DUST
Ingred Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY TRACT
IRRITANT. EFFECT MAY CAUSE IRRITATION OF THE THROAT, NASAL PASSAGES
& RESPIRATORY SYSTEM; INFLAMMATION/DELAYED LUNG INJURY. SKIN:
ABSORPTION/INFLAMMATION. EYES: IRRITATIO N, ABRASIVE. AIRBORNE DUST
GENERATED DURING USE MAY CAUSE SILICOSIS/SEVERE RESPIRATORY
DISEASE; PNEUMOCONIOSIS.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, CONGESTION, INFLAMMATION, CHEST
PAIN, DIFFICULT BREATHING, COUGHING, NAUSEA
Medical Cond Aggravated by Exposure:EXISTING CHRONIC LUNG CONDITIONS;
BRONCHITIS, EMPHYSEMIA, ASTHMA.
* First Aid Measures *
First Aid:INHALATION: REMOVE FROM SOURCE OF EXPOSURE. EYES: FLUSH
W/WATER. SKIN: WASH W/SOAP & WATER. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
* Accidental Release Measures *
Spill Release Procedures:IF UNCONTAMINATED, RECOVER & REUSE. IF
CONTAMINATED, COLLECT IN SUITABLE CONTAINERS. USE DUSTLESS SYSTEMS
FOR HANDLING, STORAGE & CLEANUP SO THAT AIRBORNE DUST DOESN'T
EXCEED THE PEL.
*Handling and Storage *
Other Precautions:DON'T BREATHE DUST GENERATED BY USE OF THIS PRODUCT.
AVOID CREATING DUST IN CLOSED AREAS W/O EXHAUST VENTILATION.
ACCUMULATION OF FORMS/DUST ON FLOOR MAY PRESENT A SLIPPAGE HAZARD
TO PERSONNEL. PROMPT LY CLEAN UP MATERIAL.
* Physical/Chemical Properties *
Spec Gravity:2.2-3.4
Solubility in Water:INSOLUBLE
Appearance and Odor:BLUE SOLID FORM W/NO ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS; FLOURINE, CHLORINE TRIFLUORIDE, MANGANESE
TRIOXIDE/OXYGEN DIFLUORIDE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:SILICA WILL DISSOLVE IN HYDROFLUORIC
ACID & PRODUCE A CORROSIVE GAS; SILICON TETRAFLUORIDE
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN LANDFILL IN ACCORDANCE W/LOCAL,
STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT NORMALLY A VAPOR HAZARD. NIOSH/MSHA APPROVED
MASK OR RESPIRATOR FOR ORGANIC VAPORS MAY BE NECESSARY IF HEATED,
AS AMINE AND SOLVENT VAPORS MAY BE LIBERATED. FOLLOW OSHA
Ventilation:MUST PROVIDE ADEQUATE VENTILATION IF HEATED.
Other Protective Equipment:HAVE EYE BATH AVAILABLE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC: FULL-FACE SCBA & IMPERVIOUS PROT CLTHG. WATER MAY BE
USED TO KEEP FLAMM STRUCTURES WET. FIRST AID PROC: COMPLETELY
CONSCIOUS/ALERT, & HAS SWALLOWED LG QTYS, THEN GIVE LUKEWARM WATER
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:DIETHYLENE TRIAMINE
OSHA PEL:1 PPM
Ingred Name:TRIETHYLENETETRAMINE.
Ingred Name:PHENOL, NONYL (4-NONYL HYDROXYBENZENE). VP: 0.9. CONTAINS A
OSHA PEL:SEE INGREDIENT NAME
ACGIH TLV:SEE INGREDIENT NAME
Ingred Name:SUPP DATA: CLTHG/SHOES CLEANED. IF IRRITATION PERSISTS, GET
MEDICAL ATTENTION. IF STICKY, USE WATERLESS CLEANER FIRST.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE INJURY TO SKIN FOLLOWING
REPEATED OR PROLONGED CONTACT AND MAY CAUSE SKIN SENSITIZATION OR
OTHER ALLERGIC RESPONSES. EYE CONTACT MAY CAUSE SEVERE IRRITATION.
INHALATION MAY CAUSE IRRITATION TO NOSE, THROAT OR LUNGS.
INGESTION MAYBE HARMFUL IF SWALLOWED.
Explanation of Carcinogenicity:NONE SPECIFIED BY MANUFACTURER.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
HOLDING LIDS OPEN. GET MED ATTN. INHAL: REMOVE TO FRESH AIR. GIVE
O*2 IF BRTHG DFCLT. GIVE ARTF RESP IF NOT BRTHG. GET MED ATTN. KEEP
VICTIM QUIET. INGEST: DO NOT INDUCE VOMIT. IFVOMIT OCCURS
SPONTANEOUSLY, KEEP HEAD BELOW HIPS TO PVNT ASPIR INTO LUNGS. GET
MED ATTN. NEVER GIVE AN UNCON PERSON LIQ, BUT IF VICTIM IS (SEE
SUPP DATA)
* Fire Fighting Measures *
Flash Point Method:SCC
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:PVNT HUMAN EXPOS TO FIRE, SMOKE, FUMES OR
PRODS OF COMBUST. EVAC NON-ESSENTIAL PERS FROM FIRE AREA. FIRE
FIGHTERS SHOULD WEAR NIOSH/MSHA APPRVD (SEE SUPP DATA)
Unusual Fire/Explosion Hazard:SEALED CONTAINERS MAY EXPLODE IF
OVERHEATED.
* Accidental Release Measures *
Spill Release Procedures:COMPLETELY ABSORB WITH INERT MATERIAL
(VERMICULITE), SWEEP OR SCOOP UP AND PUT IN DISPOSAL CONTAINER.
FLUSH AREA WITH WATER BUT PREVENT WASHINGS FROM ENTERING SEWERS AND
WATERWAYS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM FLAMES AND HIGH
TEMPERATURES.
Other Precautions:AVOID PROLONGED SKIN CONTACT. AVOID BREATHING VAPORS.
( PT). SKIN: FLUSH W/H*2O WHILE REMOVING CONTAM CLTHG/SHOES. FOLLOW
* Physical/Chemical Properties *
HCC:C1
Vapor Pres:SEE INGRED
Vapor Density:> AIR
Evaporation Rate & Reference:0.0 (N-BUTYL ACETATE)
Appearance and Odor:CLEAR, COLORLESS LIQUID
Percent Volatiles by Volume:9.8
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES AT DECOMPOSITION, SUCH AS
CO*2, CO, NO*X, HFO*X.
* Disposal Considerations *
Waste Disposal Methods:PLACE IN CLOSED CONTAINERS. DISPOSAL MUST BE IN
ACCORDANCE WITH CURRENT LOCAL, STATE AND FEDERAL REGULATIONS.
CONTACT AN APPROVED DISPOSAL FACILITY.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF VENTILATION IS INADEQUATE, USE RESPIRATORY
MASK APPROVED BY NIOSH/MESA.
Ventilation:LOCAL EXHAUST: SATISFACTORY.
Supplemental Safety and Health
WT: 7.2-8 LB/GAL
* Product Identification *
* Composition/Information on Ingredients *
Fraction by Wt: 1-3%
Ingred Name:BUTANE
Ingred Name:PROPANE
Ingred Name:STODDARD SOLVENT
Ingred Name:TOLUENE (SARA III)
Ingred Name:LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:
IRRITATION/REDNESS/TEARING/BLURRED VISION/CONJUNCTIVITIS. SKIN:
PROLONGED & REPEATED CONTACT MAY CAUSE MODERATE
IRRITATION/DEFATTING/DERMATITIS/SEVERE BODILY HARM/ALLERGIC
REACTION. INHALATION:
HEADACHES/NAUSEA/DROWSINESS/RESPIRATION/MUCOUS MEMBRANE/NOSE/THROAT
IRRITATION. INGESTION: HARMFUL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION/REDNESS/TEARING/BLURRED
VISION/CONJUNCTIVITIS. SKIN: PROLONGED & REPEATED CONTACT MAY CAUSE
MODERATE IRRITATTION/DEFATTING/DERMATITIS/SEVERE BODILY
HARM/ALLERGIC REACTION. INHALATION:
HEADACHES/NAUSEA/DROWSINESS/RESPIRATION/MUCOUS MEMBRANE/NOSE/THROAT
IRRITATION. INGESTION: HARMFUL.
Medical Cond Aggravated by Exposure:ALLERGY
* First Aid Measures *
CONTAMINATED AREA THOROUGHLY W/SOAP & WATER. INHALATION: REMOVE TO
FRESH AIR. IF BREATHING IS DIFFICULT, ADMINISTER OXYGEN. IF
BREATHING HAS STOPPED, GIVE ARTIFICIAL RESPIRATION. KEEP PERSON
WARM & QUIET. OBTAIN MED ATT. INGESTION: ONLY INDUCE VOMITING AT
INSTRUCTION OF PHYSICIAN. KEEP WARM & QUIET. OBTAIN MED ATT.
* Fire Fighting Measures *
Lower Limits:1.9%
Upper Limits:8.5%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS & FULL
PROTECTIVE CLOTHING. WATER MAY BE USED TO COOL CLOSED CONTAINERS TO
PREVENT PRESSURE BUILD-UP/POSSIBLE EXPLOSION.
CUBIC FEET OF AIR MAY REACH EXPLOSION LEVEL. EXPOSURE TO HIGH
TEMPERATURES MAY CAUSE BURSTING.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION & VENTILATE
AREA. WIPE UP W/INERT MATERIAL.
*Handling and Storage *
Handling and Storage Precautions:CONTENTS UNDER PRESSURE. AVOID STORING
NEAR RADIATOR, STOVE, OPEN FLAMES & DIRECT SUNLIGHT. DON'T STORE AT
Other Precautions:DON'T INCINERATE OR PUNCTURE CAN.
* Physical/Chemical Properties *
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:AEROSOL LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS, FIRE, PRESSURE, HIGH
TEMPERATURES, OPEN FLAMES, DIRECT SUNLIGHT, SOURCES OF IGNITION
Hazardous Decomposition Products:CO, CO2
* Disposal Considerations *
Waste Disposal Methods:FOLLOW APPLICABLE FEDERAL, STATE, & LOCAL LAWS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIREDD IF GOOD VENTILATION IS
MAINTAINED. WEAR RESPIRATRO (MSHA/NOISH) SUITABLE FOR
CONCENTRATIONS AND TYPES OF AIR CONTAMINANTS ENCOUNTERED.
Ventilation:MECHANICAL LOCAL EXHAUST VENTILATION AT POINT OF
CONTSAMINANT RELEASE.
Other Protective Equipment:PROTECTIVE CLOTHING, SAFETY SHOWER, AND
EYEWASH FACILITY.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:RAJESH S. PATEL
POLYMERS
* Composition/Information on Ingredients *
Ingred Name:MODIFIED ALIPHATIC AMINE
* Hazards Identification *
Health Hazards Acute and Chronic:INHALATION: VAPOR OR MIST CAN IRRITATE
THE NOSE AND THROAT. EYE CONTACT: SEVERELY IRRITATING TO THE EYES;
POSSIBLY PERMANENT EYE INJURY. SKIN: SEVERELY IRRITATING; HARMFUL
IF ABSORBED THROUGH SKIN.INGESTION: SUBSTANCE WILL CAUSE
BURNING AND SWELLING OF MOUTH, THROAT AND ABDOMEN.DELAYED
EFFECTS: PROLONGED OR REPEATED EXPOSURE CAN CAUSE ALLERGIC
REACTION.
Medical Cond Aggravated by Exposure:ECZEMA, SKIN, EYE, OR RESPIRATORY
DISEASES
* First Aid Measures *
First Aid:INHALATION: MOVE SUBJECT TO FRESH AIR. GIVE OXYGEN IF
BREATHING ID DIFFICULT. EYE AND SKIN: FLUSH EYES WITH A LARGE
ATTENTION. WASH S KIN THOROUGHLY WITH SOAP AND WATER. REMOVE AND
WASH CLOTHING BEFORE REUSE. INGESTION: IF SWALLOWED DILUTE BY
GIVING 2 GLASSES OF WATER TO DRINK. SEE A PHYSICIAN. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSIOUS PERSON. NOTE TO PHYSICIAN:
ALLERGIC DERMATITIS OR RESPIRATORY RESPONSE IN SUSCEPTIBLE
INDIVIDUALS MAY BE DELAYED. IT MAY APPEAR AFTER WEEKS OF EVEN
MONTHS OF FREQUENT AND PROLONGED CONTACT.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:CO2, FOAM, DRY CHEMICAL, WATER.
Fire Fighting Procedures:WEAR BREATHING APPARATUS (MSHA/NOISH-APPROVED,
PRESSURE DEMAND, SELF-CONTAINED OR EPUIVALENT.) AND FULL PROTECTIVE
GEAR.
Unusual Fire/Explosion Hazard:DECOMPOSITION AND COMBUSTION PRODUCTS MAY
BE TOXIC.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE THE SPILL AREA. WEEAR PROTECTIVE
CLOTHING. DIKE AND ABSORB SPILL WITH INERT MATERIAL. TRANSFER TO
CONTAINERS SUITABLE FOR DISPOSAL. REMOVE CONTAMINATED CLOTHING
PROMPTLY AND WASH AFFECTEDSKIN AREAS WITH SOAP AND WATER. KEEP
SPILLS AND CLEANING RUNOFFS OUT OF MUNICIPAL SEWERS AND OPEN BODIES
OF WATER. IF SPILLED ON A POROUS SURFACE, GROUND WATER
CONTAMINATION MUST BE CONSIDERED.
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM EXCESSIVE HEAT (E.G.
STEAMPIPES, RADIATORS, ), FROM SOURCES OF IGNITION, AND FROM
REACTIVE MATERIALS. DO NOT STORE NEAR FOOD OR FEED. CORROSIVE TO
COPPER AND BRASS ON LONG STORAGE.AVOID ALL EYE AND SKIN CONTACT.
* Physical/Chemical Properties *
Vapor Density:>AIR
Volatile Org Content %:1
Evaporation Rate & Reference:<1 (BUTYL ACETATE =1)
Solubility in Water:APPRECIABLE
Appearance and Odor:LIGHT AMBER LIQUID/ AMMONIACAL ODOR, MILD
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, ALDEHYDES, KETONES, AND MINERAL ACIDS.
Stability Condition to Avoid:ELEVATED TEMPERATURES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN, AND ALDEHYDES.
* Toxicological Information*
Toxicological Information:IRRITATION: EYES-SEVERE, SKIN- SEVERE AND
SENSITIZER.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE LIQUID; LANDFILL OR INCINERATE
CONTAMINATED DIKING MATERIAL IN ACCORDANCE WITH LOCAL, STAT, AND
FEDERAL REGULATIONS.
* Regulatory Information *
SARA Title III Information:TOXIC SYBSTANCE CONTROL ACT (TSCA) INVENTORY
STATUYS: CHEMICAL COMPONENTS LISTED ON TSCA INVENTORY.
State Regulatory Information:CALIFORNIA SOUTH COAST AIR QUALITY
BASED ON THORETICAL CALCULATION. PENNSYLVANIA RIGHT TO KNOW
ACT: THE FOLLOWING IS REQUIRED COMPOSITION INFORMATION. THIS
PRODUCT CONTAINS: MODIFIED ALIPHATIC AMINE
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR MSHA/NIOSH-APPROVED RESPIRATOR OR
EQUIVALENT.
Ventilation:PROVIDE EXHAUST VENTILATION OR OTHER ENGINEERING CONTROLS
TO KEEP THE AIRBORNE CONCENTRATIONS BELOW TLV.
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER, LAB COAT,
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
* Product Identification *
Product ID:METHYL SALICYLATE
Preparer's Name:E. BRULL
* Composition/Information on Ingredients *
Ingred Name:METHYL SALICYLATE
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:SKIN, KIDNEY, LIVER,
CNS. ACUTE- VERY DAMGEROUS IN CASE OF INGESTION. SLIGHTLY DANGEROUS
TO DANGEROUS IN CASE OF SKIN CONTACT (IRRITANT) OF EYE CONTACT
(IRRITANT) OF INHLATION. VERY SLIG HTLY TO SLIGHTLY DANGEROUS IN
CASE OF SKIN CONTACT (PERMEATOR). THIS PRODUCT MAY IRRITATE EYES
AND SKIN UPON CONTACT. THIS SUBSTANCE IS TOXIC TO BLOOD, LUNGS, THE
NERVOUS SYSTEM, MUCOUS MEMBRANES. TOX ICITY OF THE PRODUCT TO THE
REPRODUCTIVE SYSTEM NOT AVAILABLE. REPEATED OR PROLONGED EXPOSURE
TO THE SUBSTANCE CAN PRODUCE TARGET ORGANS DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:TARGET ORGANS:SKIN, KIDNEY, LIVER, CNS. ACUTE-
VERY DAMGEROUS IN CASE OF INGESTION. SLIGHTLY DANGEROUS TO
DANGEROUS IN CASE OF SKIN CONTACT (IRRITANT) OF EYE CONTACT
(IRRITANT) OF INHLATION. VERY SLIG HTLY TO SLIGHTLY DANGEROUS IN
CASE OF SKIN CONTACT (PERMEATOR). THIS PRODUCT MAY IRRITATE EYES
AND SKIN UPON CONTACT. THIS SUBSTANCE IS TOXIC TO BLOOD, LUNGS, THE
NERVOUS SYSTEM, MUCOUS MEMBRANES. TOX ICITY OF THE PRODUCT TO THE
REPRODUCTIVE SYSTE. NOT AVAILABLE. REPEATED OR PROLONGED EXPOSURE
TO THE SUBSTANCE CAN PRODUCE TARGET ORGANS DAMAGE.
* First Aid Measures *
First Aid:EYES: REMOVE CONTACT LENSES, IF PRESENT. IMMEDIATELY FLUSH
OPEN. SEEK MEDICAL ATT'N. SKIN: REMOVE CONTAMINATED CLOTHING
QUICKLY, PROTECT ING YOUR OWN HANDS/BODY. PLACE VICTIM UNDER A
DELUGE SHOWER. GENTLY & THOROUGHLY WASH THE CONTAMINATED SKIN WITH
RUNNING WATER & NON-ABRASIVE SOAP. SEEK MEDICAL ATT'N. USE AN
ANTIBACTERIAL CREAM. INH ALATION: ALLOW VICTIM TO REST IN A
WELL-VENTILATED AREA. SEEK IMMEDIATE MEDICAL ATT'N. INGESTION:
REMOVE DENTURES IF ANY. HAVE CONSCIOUS PERSON DRINK SEVERAL GLASSES
OF WATER OR MILK. INDUCE VOMITING . SEEK MEDICAL ATT'N.
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:SMALL: USE WATER SPRAY OR FOAM, DRY CHEMICAL,
CARBON DIOXIDE. FOR LARGER FIRES USE WATER SPRAY, FOG OR FOAM. DO
NOT USE WATER JET.
Fire Fighting Procedures:NO ADDITIONAL REMARK.
Unusual Fire/Explosion Hazard:RISK OF EXPLOSION OF THIS PRODUCT IN
PRESENCE OF MECHANICAL IMPACT. NOT AVAILABLE. RISK OF EXPLOSION OF
THIS PRODUCT IN PRESENCE OF STATIC DISCHARGE. NOT AVAILABLE. NO
SPECIFIC INFORMATION IS AVAILABL E IN OUR DATABASE REGARDING THE
PRODUCTS RISKS OF EXPLOSION IN THE PRESENCE OF VARIOUS MATERIALS.
* Accidental Release Measures *
Spill Release Procedures:SMALL: ABSORB WITH AN INERT MATERIAL AND PUT
THE SPILLED MATERIAL IN AN APPROPRIATE WASTE DISPOSAL. LARGE: KEEP
AWAY FROM HEAT. KEEP AWAY FROM SOURCES OF IGNITION. STOP LEAK IF
WITHOUT RISK. FINISH CL EANING BY SPREADING WATER ON CONTAMINATED
SURFACE AND ALLOW TO EVACUATE THROUGH THE SANITARY SYSTEM.
Neutralizing Agent:NOT RELEVENT
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT AND SOURCES OF
IGNITION. EMPTY CONTAINERS POSE A FIRE RISK, EVAPORATE THE RESIDUE
UNDER A FUME HOOD. GROUND ALL EQUIPMENT CONTAINING MATERIAL. DO NOT
INGEST. DO NOT BREATHE GAS, FU MES, VAPOR OR SPRAY. IN CASE OF
INSUFFICIENT VENTILATION, WEAR SUITABLE RESPIRATORY EQUIPMENT.
Other Precautions:IF INGESTED, SEEK MEDICAL ADVICE AND SHOW THE
CONTAINER OR THE LABEL. AVOID CONTACT WITH SKIN AND EYES. KEEP
CONTAINER DRY. KEEP IN A COOL PLACE. GROUND ALL EQUIPMENT
CONTAINING MATERIAL. KEEP CONTAIN ER TIGHTLY CLOSED. KEEP IN A
COOL, WELL-VENTILATED PLACE.
* Physical/Chemical Properties *
HCC:T6
NRC/State Lic Num:NOT RELEVANT
Solubility in Water:VERY SLIGHT
Appearance and Odor:LIQUID WITH STRONG ODOR. TASTE AND COLOR: NOT
AVAILABLE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NO SPECIFIC INFORMATION IS AVAILABLE IN OUR DATA BASE REGARDING THE
REACTIVITY OF THIS MATERIAL IN PRESENCE OF VARIOUS OTHER MATERIALS.
Hazardous Decomposition Products:CARBON OXIDES (CO AND CO2)
* Toxicological Information*
THE SUBSTANCE IS TOXIC TO BLOOD, LUNGS, THE NERVOUS SYSTEM, MUCOUS
MEMBRANES. TOXICITY OF THE PRODUCT TO THE REPRODUCTIVE SYSTEM: N/A.
VERY DANGEROUS INCASE OF INGESTION. SLIGHTLY DANGEROUS TO
DANGEROUS IN CASE OF SKIN CONTACT (IRRITANT), OF EYE CONTACT
(IRRITANT), OF INHALATION. VERY SLIGHTLY TO SLIGHTLY DANGEROUS IN
CASE OF SKIN CONTACT (PERMEATOR) .
* Ecological Information *
Ecological:TOXICITY OF THE PRODUCTS OF BIODEGRADATION: THE PRODUCTS OF
DEGRADATION ARE MORE TOXIC.
* Disposal Considerations *
Waste Disposal Methods:RECYCLE TO PROCESS, IF POSSIBLE. CONSULT YOUR
LOCAL OR REGIONAL AUTHORITIES.
* MSDS Transport Information *
Transport Information:NOT A DOT CONTROLLED MATERIAL.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:ORGANIC VAPOR RESP;SELF-CONTAINED APPRTS IF
VAPOR CONC >TLV
Ventilation:LOCAL EXHAUST IF VAPOR CONCENTRATIONS EXCESSIVE
Supplemental Safety and Health
VAPOR PRESS:0.3 MMHG.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:PIGMENTS(TYPE NOT SPECIFIED)
Ingred Name:VARNISH AS VEHICLE
* Hazards Identification *
Effects of Overexposure:INHAL OF HIGH VAPOR CONCS OR MISTS MAY LEAD TO
ASPHYXIATION.PROMPT REMOVAL TO FRESH AIR IS IMPORTANT
* First Aid Measures *
First Aid:SKIN:WASH THOROUGHLY W/SOAP & WATER.REMOVE CONTAMINATED
CLOTHING & WAS BEFORE REUSE.EYES:IMMEDIATELY FLUSH W/WATER AT LEAST
MD.INHALATION:REMOVE T O FRESH AIR IMMEDIATELY.
* Fire Fighting Measures *
Lower Limits:0.8
Upper Limits:6.8
Extinguishing Media:CO*2, DRY CHEMICAL
Fire Fighting Procedures:ELIMINATE ALL SOURCES OF IGNITION
* Accidental Release Measures *
Spill Release Procedures:EXTINGUISH ALL SOURCES OF IGNITION IN VICINITY
OF SPILL OR RELEASED VAPORS. CLEAN UP SPILLS AS SOON AS POSSIBLE.
ABSORB LARGE SPILLS W/CLAY OR DIATOMACEOUS EARTH
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, WELL-VENTILATED AREA
AWAY FROM SOURCES OF IGNITION. CONTANERS SHOULD HAVE A COMBUSTLBLE
LIQUID ""CAUTION" LABELJ
* Physical/Chemical Properties *
HCC:F4
Vapor Pres:F
Vapor Density:4.8
Solubility in Water:NEGLIGIBLE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
MA REACT WITH STRONG OXIDIZING MATERIALS
Hazardous Decomposition Products:NRML CMBSTN-CO*2, WATER
VAPOR;INCOMP.CMSTN-CO
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE W/LOCAL,STATE & FEDERAL
CODES
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF WORKPLACE EXPOSURE LIMITS ARE EXCEEDED, USE A
NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR.
Ventilation:APPROVED FUME HOOD/ADEQUATE VENTILATION.
Other Protective Equipment:EYEWASH & SAFETY EQUIPMENT.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TOXIC BY INGESTION, INHALATION & SKIN
ABSORPTION. AFTER INGESTION/INHALATION, SYMPTOMS ARE, MILD
ESPECIALLY OPTIC NERVE. MARKED IMPAIRME NT OF VISION & ENLARGEMENT
OF THE LIVERW/CHRONIC EXPOSURE. MAY DAMAGE KIDNEY & CNS SYSTEM.
RESPIRATORY FAILURE. (SUPP)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INTOXICATION, DIZZINESS, MUSCLE WEAKNESS,
NARCOSIS, BLINDNESS.
Medical Cond Aggravated by Exposure:SKIN CONDITIONS, EYE
PROBLEMS/IMPAIRED LIVER/KIDNEY FUNCTION.
* First Aid Measures *
First Aid:SKIN: WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH W/WATER FOR
INGESTION: INDUCE VOMITING. DON'T INDUCE VOMITING IF UNCONSCIOUS.
OBTAIN MED ICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:6.7
Extinguishing Media:DRY CHEMICAL, ALCOHOL FOAM, CO2, WATER MIST.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:DANGEROUS FIRE/EXPLOSION HAZARD. CLOSED
CONTAINERS EXPLODE UPON HEATING. VAPORS TRAVEL TO IGNITION SOURCES
& FLASH BACK. (SEE SUPP)
* Accidental Release Measures *
Spill Release Procedures:EVACUATE AREA. WEAR SUITABLE PROTECTIVE
EQUIPMENT. ELIMINATE IGNITION SOURCES. CONTAIN & ELIMINATE ITS
SOURCE, W/O RISK. TAKE UP & CONTAINERIZE FOR PROPER DISPOSAL. SPILL
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED. STORE IN A COOL
AREA AWAY FROM IGNITION SOURCES & OXIDIZERS. ELECTRICALLY GROUND
ALL EQUIPMENT WHEN HANDLING.
Other Precautions:DON'T BREATHE VAPOR/MIST. DON'T GET IN EYES, ON
SKIN/CLOTHING. DON'T TAKE INTERNALLY.
* Physical/Chemical Properties *
Vapor Density:1.1
Solubility in Water:MISCIBLE
Appearance and Odor:COLORLESS LIQUID W/CHARACTERISTIC ALCOHOLIC ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACIDS, OXIDIZERS, REACTIVE METALS.
Stability Condition to Avoid:HEAT, IGNITION SOURCE.
Hazardous Decomposition Products:CARBON OXIDES, FORMALDEHYDE
* Disposal Considerations *
IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:A FULL FACEPIECE WITH CARTRIDGES/CANISTERS
SPECIALLY APPROVED BY NIOSH FOR PROTECTION AGAINST
FORMALDEHYDE/TYPE C SUPPLIED AIR RESPIRATOR SHOULD BE WORN IF
NEEDED.IF RESPIRATORS ARE USED,A PROGRAM SHO ULD BE INSTITUTED TO
LEARN HOW TO USE IT
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER. PROTECTIVE
CLOTHING MADE OF MATERIAL IMPERVIOUS TO FORMALDEHYDE.
Work Hygienic Practices:THE ROUTINE USE OF A NON-ALKALINE TYPE OF SKIN
REACTION.
Supplemental Safety and Health
AVOID CONTACT WITH EYES, SKIN AND CLOTHING. WASH THOROUGHLY AFTER
HANDLING. KEEP OUT OF REACH OF CHILDREN.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:WATER
Other REC Limits:NONE SPECIFIED
Ingred Name:FORMALDEHYDE (SARA III)
Fraction by Wt: < 1%
Other REC Limits:NONE SPECIFIED
Ingred Name:POLYOXYETHYLENE TRIDECYL ALCOHOL/NONIONIC SURFACTANT
Fraction by Wt: < 1%
Other REC Limits:NONE SPECIFIED
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
Fraction by Wt: < 0.1%
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE-EYES:MAY CAUSE IRRITATION &
TEARING.SKIN:CAUSES IRRITATION.MAY CAUSE AN ALLERGIC
INHALATION:FORMALDEHYDE IRRITATES EYES,NOSE & THROAT.MAY
CAUSE RESPIRATORY SENSITIZATION.INGESTION:MAY C AUSE ABDOMINAL
PAIN,VOMITING,NAUSEA,DIARRHEA OR DIZZINESS.CHRONIC-NOT GIVEN.
Explanation of Carcinogenicity:FORMALDEHYDE PER MSDS.
Effects of Overexposure:SEE HEALTH HAZARDS SECTION.
Medical Cond Aggravated by Exposure:FORMALDEHYDE MAY AGGRAVATE
PRE-EXISTING ASTHMATIC CONDITIONS.
* First Aid Measures *
First Aid:GET MEDICAL CARE IF NEEDED.EYES/SKIN:IMMEDIATELY FLUSH WITH
VOMITING.IF CONSCIOUS,DRINK 1 GLASS OF WATER.INHALATION:REMOVE TO
FRESH AIR.PR OVIDE CPR/OXYGEN IF NEEDED.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING TO PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:ABSORB IN VERMICULITE OR OTHER SUITABLE
ABSORBENT AND PLACE IN IMPERVIOUS CONTAINER.
*Handling and Storage *
Handling and Storage Precautions:STORAGE-NONE NORMALLY NEEDED.
Other Precautions:REMOVE CONTAMINATE CLOTHING AND SHOES. WASH
CONTAMINATED CLOTHING BEFORE REUSE. THOROUGHLY CLEAN CONTAMINATED
SHOES. EMPTY CONTAINER MAY RETAIN PRODUCT RESIDUE. FOLLOW LABEL
WARNINGS EVEN AFTER CONTAI NER IS EMPTIED.
* Physical/Chemical Properties *
HCC:N1
Vapor Density:0.6
Evaporation Rate & Reference:0.4 (N-BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID; FORMALDEHYDE ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:HIGH TEMPERATURES AND FLAMES
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:DISPOSE BY INCINERATION OR CONTRACT WITH A
LICENSED CHEMICAL DISPOSAL AGENCY. DISCHARGE,TREATMENT OR DISPOSAL
MAY BE SUBJECT TO LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:APPROPRIATE RESPIRATORY PROTECTION IS REQURIED
WHEN EXPO TO AIRBORNE CONTAM IS LIKELY TO EXCEED ACCEPTABLE
LLIMITS.RESPIRATORS SHOULD BE SELECTED & USED IAW OSHA
Ventilation:EXHAUST VENTILATION.MECHANICAL VENTILATION.
Other Protective Equipment:LAB COAT.
Work Hygienic Practices:GOOD HYG PRAC SHOULD BE OBSERVE.WORK CLOTHES
SHOULD BE WASH SEPERATELY @END OF EA WORKDAY.DISPO CLOTH SHOULD BE
(SUPPLE)
Supplemental Safety and Health
WORK HYG PRAC:DISCARDED W/MATL.
* Product Identification *
Preparer's Name:ARTHUR T. HALPIN
* Composition/Information on Ingredients *
Ingred Name:ROSIN
Fraction by Wt: 2.7-9.9%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ALKYLAMINE
Fraction by Wt: 0.1-1.8%
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:INDIUM
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG/M3
Ingred Name:CASTOR OIL, HYDROGENATED
Fraction by Wt: 0.3-2.7%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYGLYCOL ETHER
Fraction by Wt: 1.8-9.0%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGEST:MAY CAUSE
HEAD,NAU,VOMIT,DIZZ,&/OR GASTROINTESTINAL IRRIT.SKIN:MAY CAUSE
RASH,ITCHING OF SKIN.INHAL:MAY CAUSE MILD RESP IRRIT.EXCESSIVE
INHAL CAUSES HEAD,DIZZ,NAU,INCOORDINATION.EYE:MAY IRRIT.
Explanation of Carcinogenicity:PER MSDS:CARCINOGENICITY/CARCINOGENICITY
INGREDS:UNKNOWN.
Effects of Overexposure:HEADACHE, NAUSEA, VOMITING, DIZZINESS,
GASTROINTESTINAL IRRIT, RASH ,ITCHING OF SKIN, MILD RESPIRATORY
IRRIT, INCOORDINATION EYE IRRIT.
Medical Cond Aggravated by Exposure:ANY EXISTING MEDICAL CONDITION MAY
BE AGGRAVATED. TARGET ORGAN:MAY CAUSE LIVER & KIDNEY DMG.
* First Aid Measures *
First Aid:INGEST:IF SWALLOWED DILUTE W/1-2 GLASSES OF MILK OR WATER &
THEN INDUCE VOMITING.SKIN:WASH W/SOAP/WATER.INHAL:MOVE PERSON TO
W/RUNNING WATER .HOLD EYELIDS APART TO ENSURE RINSING OF ENTIRE EYE
SURFACE & LIDS W/WATER.GET IMMED MED ATTN.NOTE TO DR:TREATMENT
BASED ON SOUND JUDGMENT OF PHYSICIAN & INDIVIDUAL REACTIONS OF
PATIENT.
* Fire Fighting Measures *
Extinguishing Media:FOAM.
Fire Fighting Procedures:DONT USE WATER TO EXTINGUISH FIRE.
Unusual Fire/Explosion Hazard:SENSITIVITY TO STATIC DISCHARGE IS NOT
EXPECTED.FLAMMABLE:YES.
* Accidental Release Measures *
Spill Release Procedures:WIPE,SCRAPE,OR SOAK UP IN INERT MATL & PUT IN
CONTAINER INTENDED FOR FLAMM MATLS FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CNTNR CLSD WHEN NOT IN USE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:NA
Decomp Temp:Decomp Text:NP
Spec Gravity:4.7-5.2
Viscosity:NP
Solubility in Water:INSOLUBLE
Appearance and Odor:PASTE, PINE ODOR, METALLIC GRAY COLOR
Corrosion Rate:NP
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/ACIDIC, BASIC OR OXIDZING AGENTS.
Stability Condition to Avoid:NONE KNOWN
Hazardous Decomposition Products:MAY YIELD TOXIC FUMES IF HEATED ABOVE
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IAW ACCORDANCE WITH
LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
Control Measures
*
Cage: 0F0U5
*
Contractor Summary
*
Cage: 0F0U5
Country: UK
*
Item Description Information
*
Item Manager: GSA
Item Name: FINISH,FLOOR,NONBUFFING
Unit of Issue: BX
UI Container Qty: 1
*
Ingredients
*
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT EST.
------------------------------
% Wt: 1-5
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
-----------------------------
% Wt: 1-5
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
% Wt: 1-5
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
% Wt: 1-5
Other REC Limits: NONE RECOMMENDED
ACGIH TLV: NOT ESTABLISHED
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES: MILD IRRITATION. SKIN: NOT EXPECTED TO IRRITATE.
INHALATION: NO ADVERSE EFFECTS EXPECTED. INGESTION: NOT A LIKELY ROUTE OF
EXPOSURE.
Signs And Symptions Of Overexposure: EYES: REDNESS, SWELLING, PAIN, TEARS.
First Aid: EYES: IMMED FLUSH W/LARGE AMTS WATER. GET IMMED MED AID. SKIN: FLUSH
W/LARGE AMTS WATER. IF IRRIT PERSISTS GET MED AID. INHALATION: IF
SIGNS/SYMPTOMS OCCUR, GET FRESH AIR. IF SIGNS/SYMPTOMS CONTINUE C ALL DR.
INGESTION: NO NEED FOR FIRST AID ANTICIPATED.
*
Handling and Disposal
*
ASSISTANCE. VENTILATE AREA. EXTINGUISH ALL IGNIT SOURCES. COLLECT SPILLED
MATERIAL. CLEAN UP RESIDUE W/WATER. PLACE IN U.S. DOT APPROVED CNTNR AND SEAL
.
Waste Disposal Methods: FLUSH SPENT SOLUTIONS TO WASTE WATER TREATMT SYS. IF
FOAMING REDUCE DISCHARGE RATE. INCINERATE @ PERMITTED HAZ WASTE INCINRTR IN
PRESCENSE COMBUST MAT'L. DON'T PUNCTURE/BURN CANS IN HOUSEHOLD INCINRTR .
FACILITY MUST BE ABLE TO HANDLE AEROSOL CANS.*
OF REACH OF CHILDREN. SYSTEM.
Other Precautions: AEROSOL CNTNR CONTAINS FLAMMABLE GAS UNDER PRESSURE. DON'T
PIERCE/BURN CONTAINER EVEN AFTER USE. *DISPOSE OF EMPTY CANS IN
SANITARY LANDFILL.
*
Fire and Explosion Hazard Information
*
Flash Point Text: NA
Extinguishing Media: WATER, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: WATER MAY NOT EFFECTIVELY EXTINGUISH FIRE. HOWEVER IT
SHOULD BE USED TO KEEP FIRE-EXPOSED CONTAINERS/SURFACES COOL & PREVENT
EXPLOSIVE RUPTURE.
Unusual Fire/Explosion Hazard: CLOSED CONTAINERS EXPOSED TO HEAT FROM FIRE MAY
BUILD PRESSURE & EXPLODE.
*
*
Respiratory Protection: AVOID PROLONGED INHALATION.
Ventilation: NA
Other Protective Equipment: NA
Work Hygienic Practices: DO NOT INGEST.
Supplemental Safety and Health: AVOID PROLONGED EYE OR SKIN CONTACT AND
INHALATION OF SPRAY AND MIST.
*
Physical/Chemical Properties
*
Spec Gravity: 1.0
PH: 9.5
Solubility in Water: COMPLETE
Appearance and Odor: AEROSOL LIQUID, WHITE OPAQUE, BLAND ODOR
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: HEAT
Hazardous Decomposition Products: CARBON MONOXIDE & CARBON DIOXIDE.
Hazardous Polymerization Indicator: NO
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
Transportation Information
*
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: BX
Container QTY: 1
*
Detail DOT Information
*
DOT PSN Code: DTJ
Symbols: D
DOT Proper Shipping Name: CONSUMER COMMODITY
Hazard Class: ORM-D
Label: NONE
Bulk Pack: NONE
Vessel Stow Req: A
*
Detail IMO Information
*
IMO PSN Code: AKH
IMO Proper Shipping Name: AEROSOLS/AEROSOL PRODUCT ?
UN Hazard Class: 9?
IMO Packaging Group: -
Subsidiary Risk Label: -
*
Detail IATA Information
*
IATA PSN Code: ALS
IATA Proper Shipping Name: AEROSOLS, FLAMMABLE
IATA PSN Modifier: (EACH NOT EXCEEDING 1 L CAPACITY)
IATA UN Class: 2.1
IATA Label: FLAMMABLE GAS
*
Detail AFI Information
*
AFI PSN Code: ALR
AFI Symbols: *
AFI Proper Shipping Name: AEROSOLS, FLAMMABLE, N.O.S.
AFI PSN Modifier: (EACH NOT EXCEEDING 1L CAPACITY)
AFI Hazard Class: 2.1
Special Provisions: P4
Back Pack Reference: A6.3
*
HAZCOM Label
*
Cage: 0F0U5
Company Name: PACEBROOK LTD
Country: UK
Label Required IND: Y
Status Code: C
Origination Code: G
Hazard And Precautions: EYES: MILD IRRITATION. SKIN: NOT EXPECTED TO IRRITATE.
INHALATION: NO ADVERSE EFFECTS EXPECTED. INGESTION: NOT A LIKELY ROUTE OF
EXPOSURE.
EYES: REDNESS, SWELLING, PAIN, TEARS.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIMS BY VENT, WEAR A PROPERLY FITTED ORG VAP/PARTICULATE
RESPIRATOR APPRVD BY NIOSH FOR PROT AGAINST MATLS IN ING SECTION.
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF THE
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
MFR'S TRADE NAME/PART #:PREVENTIVE ENAMEL BULKS -2. FIRE FIGHT
PROC:POSS AUTOIGNITION/EXPLOSION WHEN EXPOSED TO EXTREME HEAT.
EXPLO HAZ:PRECS. DURING EMER CNDTNS OVEREXP TO DECOMP PRODS MAY
CAUSE A HL TH HAZ. SYMPS MAY NOT BE IMMED APPARENT. OBTAIN MED
ATTN. EFTS OF OVEREXP:NO OTHER INGREDIENT IN THESE (ING 3)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (MINERAL SPIRITS). VP:
2.0
(LBS/GAL)
Ingred Name:SUPDAT:PRODUCTS IS AN IARC, NTP/OSHA LISTED CARCIN. PRLNGD
OVEREXPOS TO SOLV INGREDIENTS IN ING SECTION MAY CAUSE(ING 4)
Ingred Name:ING 3:ADVERSE EFTS TO THE LIVER & URINARY SYS. RATS EXPOSED
Ingred Name:ING 4:CANCER, HOWEVER, SUCH EXPOS LEVELS ARE NOT ATTAINABLE
IN THE WORKPLACE. RPTS HAVE ASSOC RPTD & PRLNGD (ING 6)
Ingred Name:ING 5:OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN AND
NERVOUS SYSTEM DAMAGE.
Ingred Name:WASTE DISP METH:AND LOCAL REGULATIONS REGARDING POLLUTION.
Ingred Name:OTHER PREC:THE APPLICABLE LIMITS FOR NUISANCE DUSTS ARE
Ingred Name:ING 8:(TOTAL DUST), 5 MG/M3 (RESPIRABLE FRACTION).
Ingred Name:ING 9:INHALING THE CONTENTS CAN BE HARMFUL OR FATAL.
Ingred Name:RESP PROT:RESPIRATOR APPROVED BY NIOSH FOR PROTECTION
AGAINST NON-VOLATILE MATERIALS IN SECTION 2.
Ingred Name:VENT:BELOW APPLICABLE EXPOSURE LIMITS. REFER TO OSHA
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRIT OF EYES, SKIN & RESP SYS.
MAY CAUSE NERVOUS SYS DEPRESS. EXTREME OVEREXP MAY RSLT IN
UNCONSCIOUSNESS & POSSIBLY DEATH. SIGNS & SYMPS OF OVEREXP: HDCH,
DIZZ, NAUS, & LOSS OF COORDINATION A RE INDICATIONS OF EXCESSIVE
EXPOS TO VAPS/SPRAY MISTS. REDNESS & ITCHING/BURNING SENSATION MAY
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:INDICATE EYE/EXCESSIVE SKIN EXPOS.
CHRONIC:CERTAIN PRODS CNTN QUARTZ (SEE INGRED). QUARTZ, ALSO KNOWN
AS CRYSTALLINE SILICA, IS LISTED BY IARC. LONG TERM EXPOS TO HIGH
LEVELS OF SILICA DUST, WHICH CAN OCCUR ONLY WHEN SANDING/ABRADING
THE DRY FILM, MAY CAUSE LUNG DMG (SILICOSIS) & POSSIBLY CANCER.
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
* First Aid Measures *
First Aid:INHAL: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE BREATHING.
KEEP WARM AND QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP
AND WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE RE-USE.
GET MEDICAL ATTENTION. INGEST: SEEK MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:1.0%
Upper Limits:6.0%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP . IF
H*2O IS USED, FOG NOZZLES ARE PREF. H*2O MAY BE USED TO COOL CLSD
CNTNRS TO PVNT PRESSURE BUILD-UP & (SUPDAT)
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT, ELEC EQUIP, SPARKS, &
OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
APPLICATION TO HOT SURFACES REQS SPECIAL (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBANT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:USE ONLY WITH ADEQUATE VENTILATION.
AVOID BREATHING VAPOR AND SPRAY MIST. AVOID CONTACT WITH SKIN AND
EYES.
Other Precautions:THESE COATINGS MAY CNTN MATLS CLASSIFIED AS NUISANCE
PARTICULATES (LISTED 'AS DUST' IN SECTION II) WHICH MAY BE PRESENT
AT HAZS LEVELS ONLY DURING SANDING/ABRADING OF THE DRIED FILM. IF
NO SPECIFIC DU STS ARE LISTED IN ING SECTION, (ING 8)
* Physical/Chemical Properties *
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:WASTE FROM THESE PRODUCTS MAY BE HAZ AS DEFINED
DETERM THE APPLIC EPA HAZ WASTE NUMBERS. INCIN IN APPRVD FACILITY.
DO NOT INCIN CLSD CNTNR. DISPOSE OF I/A/W/FED, STATE (ING 7)
| 1 | eyes_protection_mandatory |
Control Measures
*
*
Contractor Summary
*
*
Ingredients
*
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
(TRIS-(HYDROXYMETHYL)AMINOMETHANE)
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: MAY CAUSE IRRITATION, VOMITING, DIARRHEA, CENTRAL NERVOUS
SYSTEM DEPRESSION, WEAKNESS, COLLAPSE, COMA, RESPIRATORY PARALYSIS. CANCER
INFORMATION:AN INGREDIENT OF THIS MIXTURE IS AN EXPERIMENTAL MUTAGE N.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: PRE-EXISTING EYE, SKIN AND RESPIRATORY
TRACT DISORDERS.
PHYSICIAN. SKIN:WASH WITH SOAP AND PLENTY OF WATER. INGESTION:GIVE LARGE
QUANTITIES OF WATER. CALL PHYSICIAN IMMEDIATELY. INHALATION:REM OVE TO FRESH
AIR. GIVE ARTIFICIAL RESPIRATION IF NECESSARY. CALL PHYSICIAN.
*
Handling and Disposal
*
Spill Release Procedures: SWEEP UP POWDER. AVOID BREATHING MATERIAL. DISSOLVE
IN WATER. FLUSH DOWN THE DRAIN WITH EXCESS WATER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS.
Handling And Storage Precautions: STORE IN A COOL, DRY PLACE.
Other Precautions: AVOID CONTACT WITH EYES AND SKIN. DO NOT BREATHE DUST.
*
Fire and Explosion Hazard Information
*
Extinguishing Media: WATER, CARBON DIOXIDE, OR DRY CHEMICAL.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: MAY EMIT TOXIC FUMES IN FIRE.
*
*
Respiratory Protection: USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN (FP N).
Ventilation: ADEQUATE VENTILATION.
Other Protective Equipment: NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices: WASH THOROUGHLY AFTER HANDLING.
*
Physical/Chemical Properties
*
PH: SUPDAT
Solubility in Water: SOLUBLE
Appearance and Odor: WHITE POWDER, NO ODOR.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: MOISTURE; CONTACT WITH ACIDS, OXIDIZERS, COPPER,
BRASS OR ALUMINUM.
Materials To Avoid: NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products: MAY EMIT TOXIC FUMES OF CARBON MONOXIDE,
SULFUR OXIDES AND NITROGEN OXIDES IN FIRE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Company Name: HACH COMPANY
Label Required IND: Y
Status Code: C
Origination Code: G
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE:MAY CAUSE IRRITATION, VOMITING, DIARRHEA, CENTRAL
NERVOUS SYSTEM DEPRESSION, WEAKNESS, COLLAPSE, COMA, RESPIRATORY PARALYSIS.
CHRONIC:NONE LISTED BY MANUFACTURER.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:A NIOSH/MSHA APPROVED AIR PURIFYING DUST/MIST
RESPIRATOR.
Ventilation:GOOD GENERAL SHOULD BE SUFFICIENT TO CONTROL AIRBORNE
LEVELS.
Other Protective Equipment:PROTECTIVE CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION. INGESTION: GI
IRRITATION & INTERNAL ORGAN CONGESTION. INHALATION: RESPIRATORY
TRACT IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, NAUSEA, VOMITING, REGIDITY,
CONVULSIONS, COMA, DEHYDRATION.
* First Aid Measures *
ALERT, GIVE 2-4 CUPFULS OF MILK/WATER. INHALATION: REMOVE TO FRESH
AIR. GIVE CPR/ OXYGEN IF NEEDED. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
* Fire Fighting Measures *
Extinguishing Media:SMALL: WATER SPRAY, DRY CHEMICAL, CO2/CHEMICAL
FOAM.
Fire Fighting Procedures:WEAR APPROPRIATE PROTECTIVE CLOTHING & SCBA.
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTIVE EQUIPMENT.
VACUUM/SWEEP UP MATERIAL & PLACE INTO A SUITABLE DISPOSAL
CONTAINER. AVOID GENERATING DUSTY CONDITIONS.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. USE
W/ADEQUATE VENTILATION. MINIMIZE DUST GENERATION & ACCUMULATION.
Other Precautions:AVOID CONTACT W/EYES, SKIN/CLOTHING. DON'T
INGEST/INHALE.
* Physical/Chemical Properties *
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS/WHITE CRYSTAL SOLID; ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
METALS(IRON/STEEL)/BUILDING
MATERIALS(CEMENT)/BROMINE/TRIFLUORIDE/DICHLOROMALEIC ANHYDRIDE &
UREA/NITROGEN COMPOUNDS.
Stability Condition to Avoid:HIGH TEMPS.
Hazardous Decomposition Products:TOXIC FUMES OF SODIUM OXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS..
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:ORGANIC CANISTER OR FACE MASK REQUIRED
Ventilation:PROVIDE ADEQUATE VENTILATION. LOCAL EXHAUST IS DESIRABLE.
Other Protective Equipment:COVER TO GUARD AGAINST SPLASHING.
Supplemental Safety and Health
* Product Identification *
CAGE:OG1H3
CAGE:OG1H3
* Composition/Information on Ingredients *
Ingred Name:KEROSENE
Fraction by Wt: 1.5%
Ingred Name:METHYL SALICYLATE
Fraction by Wt: 1.0%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: ANESTHESIA, HEADACHE,
NAUSEA, DIZZINESS. INGESTION: HARMFUL OR FATAL. SKIN/EYES: SLIGHT
IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: ANESTHESIA, HEADACHE, NAUSEA,
DIZZINESS. INGESTION: BURNING IN THROAT, UNCONSCIOUSNESS.
SKIN/EYES: SLIGHT IRRITATION.
* First Aid Measures *
First Aid:INHALATION: OPEN AIRWAY, CLEAR LUNGS. INGESTION: DON'T INDUCE
MINUTES. SKIN: WIPE OFF, WASH WITH SOAP & WATER. PHYSICIAN SHOULD
TREAT PETR OLEUM DISTILLATES.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1.0%
Upper Limits:6.0%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, EXCLUDE AIR
* Accidental Release Measures *
Spill Release Procedures:AVOID OPEN OR SPARKS - PROVIDE ADEQUATE
VENTILATION. FLUSH WITH WATER TO WELL VENTILATED AREA.
* Physical/Chemical Properties *
Vapor Pres:5.5
Vapor Density:6.0
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT COLORED LIQUID WITH KEROSENE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:OPEN FLAME & SPARKS.
* Disposal Considerations *
Waste Disposal Methods:USE OIL SEWER IF POSSIBLE.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:MATERIAL MAY BE DUSTY - WEAR NIOSH/MSHA APPROVED
RESPIRATOR TO REMOVE PARTICLES.
Ventilation:LOCAL EXHAUST:REQUIRED IN ENCLOSED AREA. MECHANICAL
(GENERAL) EQUIPMENT SUITABLE FOR ABRASIVE DUST.
Other Protective Equipment:ANTI-STATIC HOSES & NOZZLES EQUIPPED WITH
DEADMAN CONTROLS. PROTECTIVE CLOTHING.
Work Hygienic Practices:REMOVE SURFACE CONTAMINANTS BY THOROUGH WASHING
OF HANDS AND FACE PRIOR TO EATING OR SMOKING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Product ID:BLACK MAGNUM
CAGE:0F3S3
CAGE:0F3S3
* Composition/Information on Ingredients *
Ingred Name:COAL SLAG ABRASIVE:CHEMICAL BONDED (CONTAINING INGS 2-4)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:IRON
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ALUMINUM (SARA III)
Ingred Name:SILICIC ACID, CALCIUM SALT; (CALCIUM SILICATE)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:POSSIBLE COUGHING, IF NO MASK OR
RESPIRATOR IS WORN. POSSIBLE ITCHING OF SKIN IF NO PROTECTIVE
CLOTHING IS WORN.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:A BRONCHIAL DISEASE SUCH AS ASTHMA
COULD BE AGGREVATED BY EXPOSURE.
* First Aid Measures *
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . EYES:IMMEDIATELY FLUSH
( ). SKIN:IF ITCHING OCCURS, WASH WITH COLD WATER AND SOAP.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:NOT APPLICABLE. MEDIA SUITABLE FOR SURROUNDING .
Fire Fighting Procedures:NOT APPLICABLE. USE NIOSH/MSHA APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT .
* Accidental Release Measures *
Spill Release Procedures:REMOVAL CAN BE PERFORMED BY CONVENIENT METHOD.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:STANDARD GOOD HOUSEKEEPING PROCEDURES.
IF MATL IS USED FOR ABRASIVE, EQUIP USED MUST BE FREQUENTLY
INSPECTED TO INSURE TIMELY REPLACEMENT.
Other Precautions:
* Physical/Chemical Properties *
Solubility in Water:LESS THAN 0.4 PPM
Appearance and Odor:BLACK GRANULES, NO ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Hazardous Decomposition Products:NONE KNOWN.
* Disposal Considerations *
Waste Disposal Methods:LANDFILL IN APPROVED LANDFILL SITE. DISPOSAL
MUST BE I/A/W FEDERAL, STATE & LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER . OTHER PROTECTIVE CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
EXPLAN OF CARCIN: CARCINOGEN. ANIMAL:SKIN, LUNG, LIVER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:BENZO(A)PYRENE (CERCLA)
OSHA PEL:0.2 MG/M3
ACGIH TLV:A2
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:HARMFUL IF SWALLOWED, INHALED OR
ABSORBED THROUGH SKIN. MAY CAUSE EYE IRRITATION. MAY CAUSE SKIN
IRRITATION. CHRONIC:CARCINOGEN. MAY ALTER GENETIC MATERIAL.
TERATOGEN. TARGET ORGAN(S):SKIN LUNGS . TO THE BEST OF
MANUFACTURER'S KNOWLEDGE, THE CHEMICAL, PHYSICAL & TOX PROPERTIES
HAVE NOT BEEN THORO INVESTIGATED.
Explanation of Carcinogenicity:BENZO (A) PYRENE:IARC MONO, SUPP, VOL 7,
BE (SUP DAT)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
MINUTES WHILE REMOVING CONTAMINATED CLOTHING AND SHOES.
INHALATION:REMOVE TO FRESH AIR. IF NOT BREATHING GIVE ARTIFICIAL
RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN. INGESTION:WASH
OUT MOUTH WITH WATER PROVIDED PERSON IS CONSCIOUS. CALL A PHYSICIAN
IMMEDIATELY.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL POWDER OR
APPROPRIATE FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:EVACUTE AREA. WEAR NIOSH/MSHA APPROVED SCBA,
DISCARD THEM AFTER USE. SWEEP UP, PLACE IN BAG & HOLD FOR WASTE
DISP. VENT AREA & WASH SPILL SITE AFTER MATERIAL PICKUP IS
COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DO NOT BREATHE DUST. DO NOT GET IN
EYES, ON SKIN, ON CLOTHING. CARCINOGEN. MUTAGEN. TERATOGEN. KEEP
TIGHTLY CLOSED. STORE IN A COOL, DRY PLACE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
Appearance and Odor:YELLOW GREEN POWDER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISSOLVE OR MIX THE MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. OBSERVE ALL FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF EXPOSURE MAY OR DOES EXCEED OCCUPATION
EXPOSURE LIMITS USE A NIOSH-APPROVED RESPIRATOR TO PREVENT
ATMOSPHERE-SUPPLYING RESPIRATOR OR AN AI R-PURIFYING RESPIRATOR.
Ventilation:EXHAUST VENTILATION SUFFICIENT TO KEEP AIRBORNE
CONCENTRATIONS BELOW RESPECTIVE TLV'S.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
* Product Identification *
CAGE:0Z2D3
CAGE:0Z2D3
* Composition/Information on Ingredients *
Other REC Limits:NONE RECOMMENDED
Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: BALANCE
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXCESSIVE INHALATION OF VAPORS CAN
CAUSE NASAL & RESPIRATORY IRRITATION. PROLONGED/REPEATED SKIN
CONTACT MAY CAUSE DRYING. EYE CONTACT CAN CAUSE IMMEDIATE
IRRITATION. PROLONGED/WIDESPREAD CONTACT WITH SKIN MAY CAUSE
HEADACHES, GASTROINESTINAL CRAMPS, NAUSEA, DIARRHEA. INGESTION MAY
CAUSE THROAT IRRITATION, DROWSINESS.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:THROAT IRRITATION, DROWSINESS, DIZZINESS,
HEADACHES, GASTROINTESTINAL CRAMPS, NAUSEA, DIARRHEA, NASAL
IRRITATION, RESPIRATORY IRRITATION, DRY CRACKING SKIN, EYE
IRRITATION. REPORTS HAVE ASSOCIATED PRO LONGED & REPEATED
OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN & NERVOUS SYSTEM
DAMAGE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH WITH SOAP AND WATER. IF IRRITATION PERSIST, GET MEDICAL
ATTENTION. INH ALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. GET
MEDICAL ATTENTION. INGESTION: DRINK 2 GLASSES OF WATER. INDUCE
VOMITING. NEVER GIVE ANYTHING BY MOUTH IF UNCONSCIOUS. CONSULT
PHYSICIAN IMMEDIATELY
* Fire Fighting Measures *
Flash Point Method:CC
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER
FOG
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR SELF CONTAINED
BREATHING APPARATUS AND FULL PROTECTIVE GEAR. COOL TANKS AND
CONTAINERS EXPOSED TO FIRE WITH WATER.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT. APPLICATION TO
HOT SURFACES REQUIRES SPECIAL PRECAUTIONS.
* Accidental Release Measures *
Spill Release Procedures:USING NON-SPARKING TOOLS, PLACE LEAKING
CONTAINERS IN A WELL-VENTILATED AREA. AVOID BREATHING VAPORS.
ELIMINATE ALL SOURCES OF IGNITION. NOTIFY PROPER AUTHORITIES IF
PUBLIC WATERS OR SEWERS ARE CONTAM INATED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING AND INHALING THE CONTENTS MAY BE HARMFUL OR FATAL.
Other Precautions:SPECIAL NOTES TO ATTENDING PHYSICIAN: THERE IS NO
SPECIFIC ANTIDOTE. TREATMMENT OF OVEREXPOSURE SHOULD BE DIRECTED AT
CONTROL OF THE SYMPTOMS AND THE CLINICAL CONDITION.
* Physical/Chemical Properties *
HCC:F4
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Decomp Temp:Decomp Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:> 1
Evaporation Rate & Reference:< 1 (DIETHYL ETHER=1)
Solubility in Water:COMPLETE
Appearance and Odor:RED LIQUID, ALCOHOL-TYPE ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
BORAX, STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN
* Disposal Considerations *
Waste Disposal Methods:AS A HAZARDOUS WASTE, THIS MATERIAL MUST BE
DISPOSED OF IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL
ORDINANCES.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
FITTED HALF-MASK OR FULL FACEPIECE RESPIRATOR (NIOSH/MSHA) DURING &
AFTER APPLICATION UNLESS AIR MONITORING DEMONSTRATES VAPOR/MIST
LEVELS BELOW APPLICABLE L IMITS. FOLLOW RESPRTR MFR USE DIRECTIONS
Ventilation:KEEP AIR CONCEN BELOW PEL/TLV.REMOVE DECOMP FORMED DURING
WELD/FLAME CUT COATED SURFACES.VENT VAPOR FROM BAKING FINISHES
Other Protective Equipment:EMPLOYEES SHOULD WASH PROMPTLY WHEN SKIN
BECOMES CONTAMINATED. REMOVE CLOTHING THAT BECOMES WET (TO AVOID
FLAMMABILITY).
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE. WASH
HANDS BEFORE EATING, SMOKING, OR USING RESTROOM.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:MIKE LICHATOWICH
* Composition/Information on Ingredients *
Ingred Name:GROUND LIMESTONE
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: 7%
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:PROPRIETARY INGREDIENTS (MFR STATES UNIDENTIFIED
INGREDIENTS NOT CONSIDERED HAZARDOUS UNDER FED HAZARD COMM REG)
Fraction by Wt: BALANCE
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:UNKNOWN Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:SEVERE
IRRITATION.TEARING,REDNESS,BLURRED VISION.
SKIN:REDNESS,IRRITATION.DEFATTING LEADING TO DERMATITIS.
INHAL:NASAL & RESPIRATORY IRRITATION,CNS DEPRESSION
(DIZZINESS,DROWSINESS,WEAKNESS,FATIGU E,CONFUSION)
NAUSEA,VERTIGO,UNCONSCIOUSNESS,ASPHYXIATION. INGEST:GI
IRRITATION,ABDOMINAL PAIN,NAUSEA,VOMITING,DIARRHEA.
Effects of Overexposure:CHRONIC: LIVER, KIDNEY, NS. PROLONGED EXPOSURE
TO SOLVENTS MAY CAUSE CHRONIC HEALTH EFFECTS. TARGET ORGANS: LIVER,
KIDNEYS, NS, SKIN, EYES, RESPIRATORY SYSTEM, CNS.
Medical Cond Aggravated by Exposure:NONE KNOWN
* First Aid Measures *
First Aid:INHAL:MOVE TO FRESH AIR IMMED.IF BREATH STOPPED,GIVE ARTIF
RESP.GET MED AID ASAP. SKIN:IMMED FLUSH W/PLENTY OF WATER.IF MAT'L
PENETRATES CLOTH,IMMED REMOVE CONTAM CLOTH & FLUSH SKIN W/WATER.GET
MED AI D.WASH CLOTH & DECONTAM SHOES BEFORE REUSE. EYE:IMMED FLUSH
GLASSES WATER.DON'T INDUCE VOMITING.SEE DR/POISON CTR IMMED. TREAT
SYMPTOMS.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:0.8
Upper Limits:0.0
Extinguishing Media:DRY CHEMICAL, FOAM, CO2
Fire Fighting Procedures:WEAR SCBA W/FULL FACPIECE (POSITIVE PRESSURE
MODE) & FULL PROTECT CLOTH. USE WATER TO COOL CLOSED CNTNR TO
PREVENT PRESSURE BLDUP/AUTO IGNIT/EXPLOSION W/HEAT.
Unusual Fire/Explosion Hazard:KEEP CNTNR CLSD. VAPOR HEAVIER THAN AIR,
TRAVEL ON GRND TO IGNIT SOURCE. NO HEAT/IGNIT. CLSD CNTNRS MAY
EXPLODE W/HEAT. APP TO HOT SRFC REQUIRE SPCL PRECAUTIONS
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE IGNITION SOURCES. MINIMIZE BREATHING
VAPORS. AVOID SKIN CONTACT. SMALL: ABSORB W/INERT MAT'L
(CLAY,SOIL,COMMERCL ABSORBNT) SHOVEL RECLAIMED LIQ & ABSORBENT INTO
RECOVERY DRUMS. LRG: DIKE. RE CLAIM INTO RECOVERY/SALVAGE DRUMS OR
TANK TRUCK.
*Handling and Storage *
Handling and Storage Precautions:AVOID STORAGE IN HIGH TEMPERATURE
AREAS OR NEAR FIRE OR OPEN FLAME. KEEP CONTAINER CLOSED WHEN NOT IN
USE. AVOID ROUGH HANDLING
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTY. DO NOT WELD OR FLAME CUT ON EMPTY DRUMS. SHOCK FROM DROPPING
MAY SPLIT CONTAINER. CONTACT LENSES SHOULD NOT BE WORN WHEN WORKING
WITH THIS MATE RIAL.
* Physical/Chemical Properties *
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID, ODOR OF SOLVENTS
Corrosion Rate:MINIMAL
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, STRONG ACIDS
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:CAN PRODUCE CARBON MONOXIDE AND/OR
CARBON DIOXIDE.
Conditions to Avoid Polymerization:HIGH TEMPERATURES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL,
(IGNITABLE).
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:OUTDOOR/OPEN AREA W/ UNRSTR VENT:USE NIOSH/MSHA
MECH FILTER.RSTR VENT:USE NIOSH/MSHA CHEM/MECH FILTER CONFINED:USE
NIOSH/MSHA AIR SUPPLY RESP HOODS.USE NIOSH/MSHA APPROV RESP FOR
FLAME CUT,WELD,BRAZ,S AND OF MAT.COATED W/ PROD.
Ventilation:PROVIDE GEN.DILUTION OR LOCAL EXHST.VENT IN VOL & PATTERN
TO KEEP AIR CONTAM CONC BELOW APPLICABLE(SEE OTHER PRECAUTION)
Other Protective Equipment:SOLVENT IMPERMEABLE CLOTHING & BOOTS
Work Hygienic Practices:REMOVE & WASH SOILED CLOTHING BEFORE REUSE.WASH
HANDS BEFORE EATING,SMOKING OR USING THE WASHROOM
Supplemental Safety and Health
SYMP OF OVEREXP:DUST FOR YRS MAY CAUSE DUST DISEASE OF LUNGS. HANDL
STORAGE PREC:NOT USED.DON T TRANSFER CONTENTS TO BT OR OTHER
UNLABLED CONTR.KEEP OUT OF REACH OF CHILDREN.
* Product Identification *
Product ID:INTERIOR/EXTERIOR ALKYD SEMI-GLOSS SUP DATA
* Composition/Information on Ingredients *
Ingred Name:ALIPHATIC PETROLEUM DISTILLATE
Fraction by Wt:
Other REC Limits:
OSHA PEL:
ACGIH TLV:
Ingred Name:MINERAL SPIRITS
OSHA PEL:
ACGIH TLV:
Ingred Name:ODORLESS MINERAL SPIRITS
OSHA PEL:
ACGIH TLV:
Ingred Name:AMORPHOUS SILICA
ACGIH TLV:0.1MG/M(TOAL DUST)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Health Hazards Acute and Chronic:SEE SIGNS & SYMPTOMS OF OVEREXPOSURE.
Explanation of Carcinogenicity:N/A FPN
Effects of Overexposure:INHAL:IRRIT OF RESP.TRACT,HDHCNAUSEA
DIZZY,WEAK,& FATIGUE.EXTREME EXPOS CAN RESULT,UNCONSCIOUSNESS &
EVEN RESP.AREEST.SKIN/EYE:PRIMARY IRRIT.INGEST:STOMACH/INTESTINAL
IRRIT,NAUSEA,VOMIT,DIARRHEA.CHRON IC:RPTS ASSOC.RPTD/PROLONG OCC
OVEREXP TO SOLVENT W/ PERM BRAIN & NERVOUS SYS
DAMAGE.BREATH,SPRAY/MIST SAND, (SUP DATA)
Medical Cond Aggravated by Exposure:NONE WHEN USED IN ACCORDANCE W/
SAFE HANDLING & USE INFORMATION.
* First Aid Measures *
First Aid:INHAL:DIFFICULTY BREATHING.OBTAIN FRESH AIR.DIFFICULTY
CONTINUES SUMMON MED ASSIST.IMMED.BREATH CEASES,RESTORE USING CPR
TECHNIQUES.SUMMON MED ASSIST.EYE:FLUSH W/ LG AMTS OF H*2O FOR AT
SOAP/H*2O.REMOVE SOILED CLOTHING.GET MED ASSIST.IF IRRIT
PERSISTS.INGEST:DO NOT INDUCE VOMITING.CONSULT PHYSICIAN
IMMEDIATELY
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:
Upper Limits:
Extinguishing Media:USE CO*2,DRY CHEMICAL FOAM OR OTHER NATIONAL FIRE
PROTECTION ASSOCIATION APPROVED METHOD FOR TREATING CLASS B FIRES
Fire Fighting Procedures:SUMMON PROF FIREFIGHTER.USE FULL PROT EQUIP
INCLUDING SCBA.H*2O SPRAY INEFFECTIVE.IF H*2O USED,FOG NOZZLES
PREFERRED.FIRE/HEAT.USE H*2O TO, COOL CLOSED CONTRS.
Unusual Fire/Explosion Hazard:KEEP CONTR TIGHTLY CLLSED.ISOLATE FROM
HEAT/FLAME.CLOSED CONTR MAY EXPLODE NEVER WELD/CUT TORCH NEAR
CONTR.EMERGENCY OVEREXPOS TO DECOMP.PROD MAY OTHER PRECAUT
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION.DO NOT
SMOKE.AVOID BREATHING.VAPORS,CONTAIN SPILLED MATERIAL REMOVE W/
INERT ABSORBENT & NON SPARKING TOOLS.STORE IN CLOSED CONTAINER
UNTIL PROPERLY DISPOSED OF.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT & FLAME.DON T
Other Precautions:KEEP OUT REACH OF CHLIDREN.UNUSUAL FIRE & EXPLOSION
HAZ:CAUSE HEALTH HAZ.SYMP MAY NOT BE IMMEDIATELY APPARENT.OBTAIN
MEDICAL ATTENTION.VENT: SAFETY & HLTH STANDARDS IN MIX,CURING
ARES.RMV SAND DUST OF DRIED COAT.RMV VAPOR,LOWER LEVELS.
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:
Vapor Pres:
Vapor Density:HEAV > AIR
Spec Gravity:
pH:
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:
Appearance and Odor:
Corrosion Rate:
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:
Hazardous Decomposition Products:MAY CAUSE HAZ.FUMES WHEN HEATED TO
DECOMP.FUMES MAY CONTAIN CARBON MONOXIDE,CARBON DIOXIDE
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/ LOCAL,STATE &
FEDERAL REGULATIONS.INCINERATE ONLY IN APPROVED FACILITY.DO NOT
INCINERATE ONLY IN APPROVED FACILITY.DO NOT INCINERATE CLOSED
CONTAINERS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR FITTED POSITIVE PRESSR AIR SUPPLD RSPRTR
EFFECTIVE FOR ISOCYANATE VAPOR. WEAR RSPRTR WHILE MIX,SPRAY,TILL
PROTECTN
Ventilation:LOCAL EXHAUST VENT TO KEEP BELOW TLV. REMOVE DECOMPOSITION
PRODUCT. SEE "INDUST VENT-MANUAL RECOMMENDED PRACTICES" ACGIH
Other Protective Equipment:AS REQUIRED TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. DO NOT GET IN
EYES, ON SKIN, OR CLOTHING.
Supplemental Safety and Health
URETHANE ACTIVATOR IS ONE PART OF TWO COMPONENT MIXTURE. INTENDED TO BE
MIXED W/BASE. CONTENTS OF PACKAGE MUST BE BLENDED W/OTHER
COMPONENTS BEFORE PRODUCT CAN BE USED. BEFORE OPENING PACKAGES, BE
SUR E YOU UNDERSTAND WARNING MESSAGES & LABELS OF ALL COMPONENTS,
MIX WILL HAVE HZDS OF ALL PARTS. FOLLOW ALL PRECAUTIONS.
* Product Identification *
Kit Part:Y
Preparer's Name:W A ELLISON
* Composition/Information on Ingredients *
Other REC Limits:NONE RECOMME
Ingred Name:1,6-HEXANE METHYLENE DIISOCYANATE (RESIN)
Fraction by Wt: <5%
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:POLYMERIC HEXAMETHYLENE DIISOCYANATE (RESIN)
Other REC Limits:MFR 1 MG/M3
Other REC Limits:NONE RECOMME
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:ACUTE; INGEST: FATAL, GI IRRIT,
NAUSEA, VOMITING. ASPIRATION INTO LUNG MAY CAUSE CHEM PNEUMONITIS
(CAN BE FATAL). INHAL: VAPOR/SPRAY HARMFUL. LUNG DAMAGE, LUNG IRRIT
& ALLERGIC RESP REACTION (MAY BE P ERMANENT). SENSITIZATION, RESP
IRRIT. EYE: SEVERE IRRIT. SKIN: PRIMARY SKIN IRRIT, SENSITIZATION
(ALLERGIC REACTION).
Effects of Overexposure:CHRONIC; REPEATED EXPOSURE TO DIISOCYANATES MAY
RESULT IN RESPIRATORY SENSITIZATION IN SOME INDIVIDUALS.
RESPIRATORY SENSITIVITY RESULTS IN ASTHMA LIKE SYMPTOMS ON
SUBSEQUENT EXPOSURE AT CONCENTRATION S BELOW TLV. REPORTS ASSOCIATE
PROLONGED/REPEATED OVEREXPOSURE WITH PERMANENT BRAIN & NERVOUS
SYSTEM DAMAGE.
Medical Cond Aggravated by Exposure:THIS PRODUCT SHOULD NOT BE USED BY
PERSONS WHO HAVE HAD CHRONIC (LONG TERM) BREATHING PROBLEMS OR
REACTIONS TO ISOCYANATES.
* First Aid Measures *
First Aid:INGEST: DONT INDUCE VOMITING. CALL POISON CTR/EMERG ROOM/DR
IMMED. INHAL:REMOVE TO FRESH AIR IMMED. IF BREATHING STOPPED, GIVE
ARTIF RESPRTN. KEEP WARM & QUIET. GET MED AID IMMED. EYE: FLUSH
W/WATER 1 5 MIN, LIFTING EYELIDS. GET MED AID. SKIN: REMOVE CONTAM
CLOTHES. WASH AFFECTED AREA W/SOAP & WATER. GET MED AID IF IRRIT
PERSISTS. NOTE TO DR:DIRECT TREATMENT AT CLINICAL CONDITION &
SYMPTOM CONTROL.
* Fire Fighting Measures *
Lower Limits:1.7
Upper Limits:7.6
Extinguishing Media:NFPA CLASS B EXTINGUISHERS (CO2, DRY CHEMICAL,
ALCOHOL FOAM) FOR FLAMMABLE LIQ. POLYMER FOAM PREFERRED FOR LARGE
FIRES.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE, USE TO COOL EXPOSED
CONTAINERS (FOG NOZZLES PREFERRED) TO PREVENT PRESSURE BUILDUP,
AUTOIGNITION OR EXPLOSION WHEN EXPOSED TO HEAT.
Unusual Fire/Explosion Hazard:DURING EMERG CONDITIONS, OVEREXPOSURE TO
DECOMPOSITION PRODUCTS MAY BE HEALTH HAZARD. SYMPTOMS MAY NOT BE
IMMEDIATELY APPARENT. OBTAIN MEDICAL AID. FLAMMABLE.
* Accidental Release Measures *
RSPRTR,EYE,HAND,BODY PROTECT.KEEP SPECTATOR AWAY.ELIMINATE IGNIT
SOURCE.DIKE W/INERT MAT'L(SAND,EARTH,ETC).TRANSFR LIQ/USED ABSORB
TO CVRD METAL CNTNR.USE NO N-SPARK TOOL.PREVENT
SEWER,STREAM,GROUNDWTR CONTAM
*Handling and Storage *
INTERNALLY. DO NOT BREATHE SANDING DUST.
Other Precautions:CLOSE CONTAINER AFTER EACH USE. DO NOT WASH & REUSE
EMPTY CONTAINERS FOR ANY PURPOSE. GROUND & BOND CONTAINERS TO
RECEIVING CONTAINER. DONT WELD, BRAZE, OR CUT ON EMPTY CNTNR. NEVER
USE PRESSURE TO EM PTY. DRUM IS NOT A PRESSURE VESSEL.
* Physical/Chemical Properties *
Vapor Density:> AIR
Spec Gravity:1.1
pH:4-7
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Solubility in Water:SLIGHT IN WATER
Appearance and Odor:LIQUID, SOLVENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS. OXIDIZING MATERIALS.
OF IGNITION.
Hazardous Decomposition Products:BURNING,INCLUDING WHEN HEATED BY
WELDING/CUTTING,WILL PRODUCE SMOKE,CARBON MONOXIDE & CARBON
DIOXIDE. OXIDES OF NITROGEN
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORD W/FED, STATE & LOCAL
LAWS/REGS. THIS PRODUCT, IF DISCARDED DIRECTLY, WOULD BE CLASSIFIED
A HAZARDOUS WASTE BASED ON ITS IGNITABILITY CHARACTERISTIC, I.E.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Product ID:EDGE SEALING COMPOUND
Preparer's Name:L. W. MCCLOSKEY
* Composition/Information on Ingredients *
Ingred Name:N-BUTYLMETHACRYLATE POLYMER; (ACRYLIC RESIN)
Ingred Name:NAPHTHOL SPIRITS
Ingred Name:TOLUENE (SARA III)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: PRODUCT IRRITATING TO EYES UPON
DIRECT CONTACT. SKIN: PROLONGED OR REPEATED SKIN CONTACT MAY DEFAT
SKIN LEADING TO IRRITATION AND DERMATITIS. INHALATION: MAY CAUSE
RESPIRATORY SYSTEM IRRITATION A ND TEMPORARY NERVOUS SYSTEM
IMPAIRMENT.SYMPTOMS OF OVEREXPOSURE INCLUDE HEADACHE, NAUSEA,
DIZZINESS, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: WEAKNESS, FATIGUE, NARCOSIS AND IN
EXTREME, UNCONSCIOUSNESS. REPEATED AND EXTREME OVEREXPOSURE TO
TOLUENE VAPORS MAY CAUSE NERVOUS SYSTEM DAMAGE. INGESTION: MAY
CAUSE GASTROINTESTINAL IRRITA TION, NAUSEA, VOMITING AND DIARRHEA.
SOLVENT ASPIRATION INTO LUNGS CAN CAUSE LUNG DAMAGE OR DEATH.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:EYE: IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST
INHALATION: REMOVE PERSON TO FRESH AIR. CALL PHYSICIAN. INGESTION:
CALL PHY SICIAN. DO NOT INDUCE VOMITING.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:CARBON DIOXIDE, FOAM AND DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:FLAMMABLE. OVERHEATED, CLOSED CONTAINERS
ADJACENT TO FIRE COULD EXPLODE DUE TO PRESSURE BUILDUP.
* Accidental Release Measures *
Spill Release Procedures:OBSERVE PREC IN ALL SECTIONS. EXTING ALL IGNIT
SOURCES. VENT AREA. COLLECT SPILLED MATL USING NON-SPARKING TOOLS.
CLEAN UP RESIDUE AND PLACE IN U.S. DEPT. OF TRANSPORTATION APPROVED
METAL CONTAINER & SEAL. USE ABSORB MATL AS NEEDED IN CLEANUP PROC.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & FLAME.
USE ONLY IN AREAS ADEQUATELY VENTILATED TO REMOVE VAPORS AND
PREVENT VAPOR BUILDUP. AVOID EYE CONTACT.
Other Precautions:AVOID PROLONGED BREATHING OF VAPORS AND PROLONGED OR
REPEATED SKIN CONTACT. KEEP CONTAINER CLOSED WHEN NOT IN USE. KEEP
OUT OF REACH OF CHILDREN.
* Physical/Chemical Properties *
HCC:F3
Solubility in Water:NIL
Appearance and Odor:CLEAR, LIQUID, SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:
Hazardous Decomposition Products:CO, CO2 AND SMOKE PARTICLES WHEN
SUBJECTED TO EXCESSIVE HEAT OR FLAME.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE ABSORBED AND BULK PRODUCT AFTER
MIXING WITH FLAMMABLE MATERIAL IN LICENSED HAZARDOUS WASTE
FACILITY. DISPOSE OF IN ACCORDANCE WITH APPLICABLE REGULATIONS.
| 1 | eyes_protection_mandatory |
Control Measures
*
Product ID: CORROSION PREVENTATIVE COMPOUND WATER DISPLACING (AEROSOL)
Cage: 0FTT5
*
Contractor Summary
*
Cage: 0FTT5
*
Item Description Information
*
Item Manager: GSA
Item Name: CORROSION PREVENTIVE COMPOUND
Unit of Issue: CN
UI Container Qty: 0
*
Ingredients
*
Other REC Limits: NONE RECOMMENDED
------------------------------
Other REC Limits: NONE RECOMMENDED
------------------------------
Other REC Limits: NONE RECOMMENDED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Other REC Limits: NONE RECOMMENDED
------------------------------
Other REC Limits: NONE RECOMMENDED
------------------------------
Other REC Limits: NONE RECOMMENDED
------------------------------
Other REC Limits: NONE RECOMMENDED
------------------------------
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
------------------------------
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 5 MG/M3
-----------------------------
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT RELEVANT
ACGIH TLV: NOT RELEVANT
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: YES
OSHA: NO
Effects of Exposure: EYE: IRRITATION. SKIN: IRRITATION. INHALATION: HEADACHE,
NAUSEA, VOMITING, HARMFUL/FATAL. BRAIN/NS DAMAGE, ANESTHETIC (LIGHT
HEADED/STAGGERING/GIDDINESS).
Explanation Of Carcinogenicity: SOLVENT EXTRACTED MINERAL OIL LISTED BY IARC
First Aid: SKIN: WASH W/SOAP & WATER, WASH CLOTHES BEFORE REUSE. EYE: FLUSH
INDUCE VOMITING. GET IMMEDIATE MEDICAL AID. INHALATION: GET F RESH AIR. GET
MEDICAL AID. NEVER GIVE ANYTHING BY MOUTH TO UNCONSCIOUS PERSON.
*
Handling and Disposal
*
Spill Release Procedures: VENTILATE/REMOVE IGNITS. PICK UP SPILL W/INERT
ABSORBENT. SWEEP UP TO CLOSABLE CONTAINER. DON'T BREATHE VAPOR.
Waste Disposal Methods: ACCORDING TO FEDERAL, STATE, LOCAL REGULATIONS.
Handling And Storage Precautions: KEEP AWAY FROM CHILDREN. CONTENTS UNDER
SKIN/EYE CONTACT.
*
Fire and Explosion Hazard Information
*
Flash Point Method: TOC
Flash Point Text: NONE
Lower Limits: 2.2
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER SPRAY.
Fire Fighting Procedures: WATER MAY BE INEFFECTIVE. USE WATER TO KEEP
FIRE-EXPOSED CONTAINERS COOL. WEAR SCBA.
Unusual Fire/Explosion Hazard: DO NOT SPRAY NEAR OPEN FLAME, SPARKS, HEAT. USE
W/GOOD VENTILATION.
*
*
Respiratory Protection: NONE
Ventilation: LOCAL EXHAUST PREFERRED, MECHNAICAL ACCEPTIBLE.
Other Protective Equipment: IMPERVIOUS CLOTHES, EYEWASH, SAFETY SHOWER.
Work Hygienic Practices: DON'T EAT, SMOKE WHILE USING PRODUCT. WASH HANDS AFTER
USE.
*
Physical/Chemical Properties
*
M.P/F.P Text: NOT EST.
Decomp Text: NOT EST.
PH: NA
Viscosity: NOT EST.
Solubility in Water: INSOLUBLE
Appearance and Odor: DARK BLUE LIQUID, SOLVENT ODOR
Corrosion Rate: NA
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: EXTREME HEAT, FLAMES, SPARKS.
Materials To Avoid: NA
Hazardous Decomposition Products: CARBON DIOXIDE, CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
Transportation Information
*
Product ID: CORROSION PREVENTATIVE COMPOUND WATER DISPLACING (AEROSOL)
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: CN
Container QTY: 0
*
Detail DOT Information
*
DOT PSN Code: DTJ
Symbols: D
DOT Proper Shipping Name: CONSUMER COMMODITY
Hazard Class: ORM-D
Label: NONE
Bulk Pack: NONE
Vessel Stow Req: A
*
Detail IMO Information
*
IMO PSN Code: AKH
IMO Proper Shipping Name: AEROSOLS/AEROSOL PRODUCT ?
UN Hazard Class: 9?
IMO Packaging Group: -
Subsidiary Risk Label: -
*
Detail IATA Information
*
IATA PSN Code: ALS
IATA Proper Shipping Name: AEROSOLS, FLAMMABLE
IATA PSN Modifier: (EACH NOT EXCEEDING 1 L CAPACITY)
IATA UN Class: 2.1
IATA Label: FLAMMABLE GAS
*
Detail AFI Information
*
AFI PSN Code: ALR
AFI Symbols: *
AFI Proper Shipping Name: AEROSOLS, FLAMMABLE, N.O.S.
AFI PSN Modifier: (EACH NOT EXCEEDING 1L CAPACITY)
AFI Hazard Class: 2.1
Special Provisions: P4
Back Pack Reference: A6.3
*
HAZCOM Label
*
Product ID: CORROSION PREVENTATIVE COMPOUND WATER DISPLACING (AEROSOL)
Cage: 0FTT5
Company Name: LHB INDUSTRIES
Label Required IND: Y
Status Code: A
Origination Code: G
Hazard And Precautions: EYE: IRRITATION. SKIN: IRRITATION. INHALATION:
HEADACHE, NAUSEA, VOMITING, HARMFUL/FATAL. BRAIN/NS DAMAGE, ANESTHETIC (LIGHT
HEADED/STAGGERING/GIDDINESS).
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR A PROPERLY FITTED VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA FOR USE W/PAINTS DURING
APPLICATION & UNTIL VAPORS& SPRAY MISTS ARE EXHAUSTED.
Ventilation:SUFFICIENT VENTILATION IN VOLUME & PATTERN TO KEEP
CONTAMINANTS BELOW EXPOSURE LIMITS.
Other Protective Equipment:SAFETY GLASSES W/SIDE SHIELDS, COVERALLS,
PROTECTIVE CREAMS MAY BE USED FOR EASE OF CLEAN UP.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE
EATING/SMOKING.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:T R LOUER
* Composition/Information on Ingredients *
Ingred Name:TITANIUM DIOXIDE, TIO2 (SUSPECTED ANIMAL CARCINOGEN, IARC
Ingred Name:FATTY ACIDS, LINSEED OIL, REACTION PRODUCTS POLYMER;
Ingred Name:2-BUTANONE (METHYL ETHYL KETONE) (MEK)
Fraction by Wt: 4%
Ingred Name:LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA, LACOLENE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE NOSE & THROAT
IRRITATION & NERVOUS SYSTEM DEPRESSION. EYES: BURNS/IRRITATION.
SKIN: IRRITATION, DERMATITIS. REPEATED/PROLONGED OVEREXPOSURE TO
SOLVENTS MAY CAUSE PERMANENT BRAIN& NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, NAUSEA,
STAGGERING GAIT, CONFUSION, UNCONSCIOUSNESS, DISCOMFORT.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR, PREFERABLY
MOUTH-TO-MOUTH, IF NECESSARY. EYES: IMMEDIATELY FLUSH W/PLENTY OF
ATTENTION IN ALL CA SES.
* Fire Fighting Measures *
Flash Point Method:CC
Lower Limits:0.8
Extinguishing Media:FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT W/SCBA. WATER
FOG NOZZLES MAY BE USED TO PREVENT PRESSURE BUILD-UP.
VAPORS WHICH, WHEN MIXED W/AIR, CAN BURN/BE EXPLOSIVE. FINE
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA. REMOVE IGNITION SOURCES.
PREVENT SKIN CONTACT & BREATHING OF VAPOR. CONFINE & REMOVE W/INERT
ABSORBENT.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & FLAME.
CLOSE CONTAINER AFTER EACH USE. GROUND CONTAINERS WHEN POURING.
Other Precautions:DON'T SAND, FLAME CUT, BRAZE/WELD DRY COATING W/O
NIOSH/MSHA APPROVED RESPIRATOR/APPROPRIATE VENTILATION. OBSERVE
LABEL PRECAUTIONS. DON'T BREATHE VAPOR/MISTS.
* Physical/Chemical Properties *
Vapor Density:>1
VOC Grams/Liter:4.5
Evaporation Rate & Reference:SLOWER THAN ETHER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS, FLAME & OTHER IGNITION
SOURCES.
Hazardous Decomposition Products:CO, CO2, SMOKE, OXIDES OF HEAVY METALS
FROM THE INGREDIENTS OF THE PRODUCT.
* Disposal Considerations *
Waste Disposal Methods:DON'T ALLOW MATERIAL TO CONTAMINATE GROUND WATER
SYSTEMS. INCINERATE ABSORBED MATERIAL IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T INCINERATE IN CLOSED CONTAINERS.
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:IF HANDLED INDOORS, PROVIDE MECHANICAL EXHAUST VENTILATION.
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
COVERALLS/LONG SLEEVED SHIRT & LONG PANTS. WEAR SHOES PLUS SOCKS.
Work Hygienic Practices:CLTHG CONTAM W/MATL MUST BE REMOVED IMMED & ALL
SKIN WASHED THORO. PERS WORKING W/THIS PROD FOR LONGER PERIOD (ING
Supplemental Safety and Health
PH: 3.7-3.8. FIRE FIGHT PROC: DIKE AREA TO PVNT WATER RUNOFF. MATLS TO
AVOID: PROD IS RAPIDLY HYDROLYZED AT PH>7.0 OR <5.0. HAZ DECOMP
PROD: & POLYM RELEASING VOLAT MALODOROUS & INFLAM CMPDS SUCH AS D
IMETHYL SULFIDE. INEXPEDIENT STOR MAY INDUCE FORM OF MORE TOX &
SYNERGISTIC CONTAMINANT ISOMALATHION.
* Product Identification *
CAGE:CHEMN
CAGE:CHEMN
* Composition/Information on Ingredients *
Ingred Name:SUCCINIC ACID, MERCAPTO-, DIETHYL ESTER, S-ESTER WITH
O,O-DIMETHYLPHOSPHORODITHIOATE; (MALATHION) (CERCLA)
Ingred Name:FIRST AID PROC: REPEAT UNTIL VOMIT IS CLEAR. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCON PERS. MAKE PATIENT LIE DOWN(ING 3)
Ingred Name:ING 2: & KEEP STEADY. GET MED ATTN IMMED. EYES/SKIN: IMMED
Ingred Name:ING 3: REMOVING CONTAM CLTHG & SHOES. SEE MD IMMED. NOTE TO
MD: PROD IS A CHOLINISTERASE INHIBITOR AFFECTING (ING 5)
Ingred Name:ING 4: CENTRAL & PERIPHERAL NERV SYS & PRODUCING CARD &
RESP DEPRESS. ANTIDOTE: FOR MORE SPECIFIC INFO CONT NEHC .
Ingred Name:SPILL PROC: INSTRUCTIONS PROVIDED UNDER DISP. RINSE AREA
W/SODA LYE. LGE LIQ SPILLS ON FLOOR/OTHER IMPERVIOUS (ING 7)
Ingred Name:ING 6: SURF SHOULD BE CONTAINED/DIKED & THEN ABSORBED
W/INERT ABSORB MATL SUCH AS HYDRATED LIME, SAWDUST, (ING 8)
Ingred Name:ING 7: FULLER'S EARTH/OTHER ABSORB CLAYS. COLLECT CONTAM
ABSORB, PLACE IN METAL DRUM & DISP OF I/A/W INSTRUCTIONS(ING 9)
Ingred Name:ING 8: PROVIDED UNDER DISP. RINSE AREA W/SODA LYE. LGE
Ingred Name:ING 9: METAL DRUMS & DISP OF I/A/W INSTRUCTIONS PROVIDED
DISPOSED OF THROUGH PROPER INCINERATION.
Ingred Name:WASTE DISP METH: PROCEDURES APPROVED BY STATE, LOCAL AND
FEDERAL AUTHORITIES MUST, HOWEVER, BE OBSERVED.
NITRILE RUBBER OR VITON.
Ingred Name:HYGIENE PRACT: SHOULD HAVE FREQUENT BLOOD TESTS OF THEIR
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CHOLINISTERASE INHIBITOR OF LOW
MAMMALIAN TOX. RAPIDLY ENTERS BODY ON CONT W/ALL SKIN SURFS & EYES.
RPTD EXPOS MAY, W/OUT WARNING, CAUSE INCRD SUSCEPTIBILITY TO DOSES
OF ANY CHOLINISTERASE INHI BITOR. TOX INFO: SLIGHTLY IRRIT TO SKIN&
EYES.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HDCH, NAUS, VOMIT, CRAMPS, WEAK, BLURRED
VISION, PIN-POINT PUPILS, TIGHTNESS IN CHEST, LABORED BRTHG,
NERVOUSNESS, SWEATING, WATERING OF EYES, DROOLING/FROTHING OF MOUTH
& NOSE, MUSCLE SPASMS & COMA.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:CALL MD, CLINIC/HOSPITAL IMMED. EXPLAIN THAT PATIENT HAS BEEN
EXPOSED TO MALATHION-AN ORGANOPHOSPHORUS INSECTICIDE-& DESCRIBE
HIS/HER CNDTN. MOVE IMMED FROM CONTAM AREA. INHAL: IF BRTHG HAS
STOPPED, S TART ARTF RESP IMMED & MAINTAIN UNTIL MD TAKES CHARGE OF
PATIENT. INGEST: IF CONSCIOUS, INDUCE VOMIT QUICKLY. DRINK 1-2
GLASSES OF WATER & INDUCE VOMIT BY TOUCHING BACK OF THROAT
W/FINGER. (ING 2)
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:DRY CHEMICAL OR CARBON DIOXIDE FOR SMALL FIRES,
WATER SPRAY OR FOAM FOR LARGE FIRES.
Fire Fighting Procedures:WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP .
KEEP CONTR COOL BY SPRAYING W/WATER IF EXPOSED TO FIRE. FIGHT FIRE
UPWIND. AVOID HEAVY HOSE STREAMS. (SUP DAT)
Unusual Fire/Explosion Hazard:THE ESSENTIAL BREAKDOWN PRODUCTS ARE
DIMETHYL SULFIDE, SULFUR DIOXIDE, CARBON MONOXIDE, CARBON DIOXIDE,
PHOSPHORUS PENTOXIDE, NITROGEN OXIDES.
* Accidental Release Measures *
Spill Release Procedures:OBSERVE ALL PROT & SFTY PREC WHEN CLEANING UP
SPILLS. SML LIQ SPILLS ON FLOOR/OTHER IMPERVIOUS SURF SHOULD BE
SWEPT UP W/INERT ABSORB SUCH AS HYDRATED LIME, SAWDUST, FULLER'S
EARTH/OTHER ABSORB CLAYS. SCOOP INTO PROPER CONTRS & DISP OF I/A/W
(ING 6)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STABLE WHEN STORED AT TEMPERATURES NOT
LOCAL HEATING ABOVE THIS TEMPERATURE SHOULD BE AVOIDED.
* Physical/Chemical Properties *
pH:SUPDAT
Appearance and Odor:COLORLESS TO PALE YELLOW LIQUID, SLIGHTLY AROMATIC
ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, AMINES & STRONG OXIDIZING CMPDS. IT CAN CORRODE IRON,
STEEL, TIN PLATE, LEAD, & COPPER. (SUP DAT)
Stability Condition to Avoid:WILL DECOMPOSE RAPIDLY WHEN HEATED TO
INDUCING EXPLOSION.
Hazardous Decomposition Products:DECOMP IS DEPENDENT ON TIME AS WELL AS
TEMP DUE TO EXOTHERMIC & AUTOCATALYTIC RXNS. RXNS INVOLVE
REARRANGEMENTS(SUP DAT)
* Disposal Considerations *
Waste Disposal Methods:SPILL & WASTE DISP PROC APPRVD BY STATE, LOC &
FED AUTH MUST BE OBSERVED. DO NOT CONTAMINATE WATER, FOOD/FEED BY
STOR & DISP. TRIPLE RINSE/EQUIVALENT CONTR; OFFER FOR
RECYCLING/RECONDITIONING/PUNCTURE & DISP OF IN SANITARY LANDFILL.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:GOWN.
Work Hygienic Practices:WORKERS SHOULD WASH THEIR HANDS AND FACES AFTER
HANDLING THESE FORMULATIONS.
Supplemental Safety and Health
PROMPTLY REMOVE CONTAMINATED CLOTHING SHOULD CONTACT OCCUR. WASH
CONTAMINATED CLOTHING BEFORE REUSE.
* Product Identification *
Preparer's Name:DR. E. HAYES
CAGE:BRIST
CAGE:0NWX1
CAGE:BRIST
* Composition/Information on Ingredients *
Ingred Name:IOPAMIDOL
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
Fraction by Wt: >1%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ISOVUE SOLUTIONS ARE INTENDED FOR
INTRAVENOUS ADMINISTRATION. ORAL: NO INFORMATION. DERMAL: NO
INFORMATION. INHALATION: THIS PRODUCT IS A LIQUID AND UNDER NORMAL
CONDITIONS OF USE IS NOT AN INHALATION HAZARD.
Explanation of Carcinogenicity:NOT CARCINOGENIC.
Effects of Overexposure:ADVERSE REACTIONS HAVE BEEN REPORTED FOLLOWING
INTRAVENOUS ADMINISTRATION OF ISOVUE SOLUTIONS, INCLUDING:
HEADACHE, NAUSEA, VOMITING, MUSCULOSKELETAL PAIN; AND HYPOTENSION.
Medical Cond Aggravated by Exposure:SENSITIVITY TO IODINE.
* First Aid Measures *
SKIN-WASH WITH SOAP & WATER. GET MEDICAL ATTENTION IF IRRITATION
DEVELOPS & PERSISTS. INGESTION-GET MEDICAL ATTENTION IMMEDIATELY.
VOMITING MAY BE INDUCED IF A PERSON IS CONSCIOUS & IF INGESTION
HAS OCCURERED WITH 3 HOURS. INHALATION-REMOVE TO FRESH AIR, IF
DIFFICULTY IN BREATHING ADMINISTER OXYGEN. IF NOT BREATHING ATTEMPT
CPR. SEE DOCTOR.
* Fire Fighting Measures *
Flash Point:NOT AVAILABLE
Extinguishing Media:USE WATER.
Fire Fighting Procedures:AS WITH ALL FIRES, EVACUATE PERSONNEL TO SAFE
AREA. WHEN THIS MATERIAL IS INVOLVED IN A FIRE WEAR, SELF-CONTAINED
BREATHING APPARATUS & FULL PROTECTIVE CLOTHING
Unusual Fire/Explosion Hazard:USE WATER TO KEEP FIRE-EXPOSED CONTAINERS
COOL. FIGHT FIRE FROM MAXIMUM SAFE DISTANCE. DIVERT RUNOFF TO A
SAFE AREA.
* Accidental Release Measures *
Spill Release Procedures:WEARING SUITABLE PROTECTIVE CLOTHING, ABSORB
LIQUID ONTO APPROPIATE ABSORBENT MATERIAL & PLACE INTO AN
SHOULD BE WORN AS A MINIMUM PREC AUTION. VENTILATE SPILL AREA &
DECONTAMINATE LATER
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE NOT
Other Precautions:IF VIALS BREAK OR MATERIAL IS SPILLED, WORKERS SHOULD
AVOID SKIN OR EYE CONTACT WITH THE LIQUID. PERSONNEL WHO HANDLE
THESE FORMULATIONS IN A NON-MANUFACTURING SETTING SHOULD USE LATEX
* Physical/Chemical Properties *
HCC:N1
pH:6.5-7
Solubility in Water:MISCIBLE
Appearance and Odor:AQUEOUS SOLUTION.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:STABLE UNDER NORMAL CONDITIONS.
Hazardous Decomposition Products:THERMAL DECOMPOSITION OR BURNING MAY
PRODUCE NOXIOUS PRODUCTS INCLUDING: CO, CO2, HI, I2 (REDDISH-BROWN
GAS), NOX.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS OR WITH THE REGULATIONS OF THE COUNTRY IN
WHICH THE MATERIAL IS USED.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF TLV OF THE PRODUCT OR ANY COMPONENT IS
EXCEEDED, USE A RESPIRATOR WITH APPROPRIATE CARTRIDGES (NIOSH
APPROVED). ENGINEERING OR MANAGEMENT CONTROLS SHOULD BE IMPLEMENTED
TO REDUCE EXPOSURE.
Ventilation:LOCAL EXHAUST MUST BE SUFFICIENT TO KEEP AIRBORNE VAPOR
CONCENTRATIONS BELOW THE TLV LIMIT.
Other Protective Equipment:SOURCE OF CLEAN WATER SHOULD BE AVAILABLE IN
WORK AREA FOR FLUSHING EYES & SKIN. WEAR IMPERVIOUS CLOTHING AS
NEEDED.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:ONEY FLEMING
* Composition/Information on Ingredients *
Ingred Name:PETROLEUM DISTILLATES
Other REC Limits:NONE RECOMMENDED
Ingred Name:XYLENE (SARA III)
Other REC Limits:NONE RECOMMENDED
Ingred Name:NON-HAZARDOUS INGREDIENTS
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:UNKNOWN Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT: IRRITATION, REDNESS,
TEARING, AND BLURRED VISION. SKIN CONTACT: PROLONG OR REPEATED
EXPOSURE CAN CAUSE MODERATE IRRITATION, DEFATTING, AND DERMATITIS.
INHALATION: NASAL AND RESPIRATORY IR RITATION, DIZZINESSS, NAUSEA,
& HEADACHE. INGESTION: CAN CAUSE GASTROINTESTINAL IRRITATION,
NAUSEA, VOMITING, DIARRHEA.
Effects of Overexposure:IF TLV'S ARE EXCEEDED SKIN CONTACT PRODUCES
REDNESS. EYE CONTACT PRODUCES REDNESS AND PAIN. INHALATION GIVES
LABORED BREATHING, DULLNESS, DROWSINESS, INGESTION CAN CAUSE
ABDOMINAL PAIN AND NAUSEA.
Medical Cond Aggravated by Exposure:DISEASES OF THE RESPIRATORY SYSTEM.
* First Aid Measures *
MINUTES, OCCASIONALLY LIFTING EYELIDS. SEEK MEDICAL ATTENTION. SKIN
CONTACT: REMOVE CONTAMINATED CLOTHING. WASH AFFECTED SKIN AREAS
WITH SOAP AND WATER. INHALATION: REMOVE TO FRESH AIR, ADMINISTER
OXYGEN IF NECESSARY, SEEK MEDICAL ATTENTION. INGESTION: KEEP PERSON
WARM, QUIET AND GET MEDICAL ATTENTION. DO NOT INDUCE VOMITING.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1
Upper Limits:6
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, OR FOAM. WATER MAY
SPREAD FIRE, USE WATER SPRAY ONLY TO COOL CONTAINERS EXPOSED TO
FIRE.
Fire Fighting Procedures:SCBA RECOMMENDED FOR FIRE FIGHTERS. WATER
SPRAY MAY BE USED FOR COOLING CONTAINERS TO PREVENT PRESSURE BLDUP
& AUTOIGNITION OR EXPLOSION WITH EXTREME HEAT.
Unusual Fire/Explosion Hazard:VAPOR HEAVIER THAN AIR. MAY TRAVEL ALONG
GROUND OR MOVED BY VENT & IGNITED BY PILOT LIGHT, OTHER FLAMES,
SPARKS, HEATERS, SMOKING, & OTHER REMOTE IGNIT SOURCES.
* Accidental Release Measures *
Spill Release Procedures:VENTILATE THE AREA. COVER SPILL WITH INERT
ABSORBENT MATERIAL AND SHOVEL WITH NON-SPARKING TOOLS INTO
CONTAINER. REMOVE CONTAINER TO A SAFE AREA AND SEAL.
Neutralizing Agent:NONE
*Handling and Storage *
Handling and Storage Precautions:STORE IN A CLEAN DRY AREA. KEEP AWAY
FROM FOOD PRODUCTS. KEEP AWAY FROM SPARKS, FIRE AND REMOTE IGNITION
SOURCES.
Other Precautions:KEEP CONTAINER TIGHTLY CLOSED. KEEP AWAY FROM
CHILDREN. ALL EQUIPMENT SHOULD BE GROUNDED TO REDUCE STATIC
ELECTRICITY HAZARD. USE NON-SPARKING TOOLS.
* Physical/Chemical Properties *
Vapor Density:> AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NO
Appearance and Odor:WHITE LIQUID WITH MILD ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:DO NOT STORE NEAR HEATED SURFACES, OPEN
FLAMES OR IGNITION SOURCES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:WASTE MATERIAL MUST BE DISPOSED OF IN ACCORDANCE
WITH FEDERAL, STATE, AND LOCAL ENVIRONMENTAL REGULATORY CONTROLS.
HAZARDOUS WASTE CHARACTERISTIC: IGNITABILITY. EPA HAZARDOUS WASTE
CODE: NONE.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:PROTECTIVE CLOTHING. SAFETY SHOWER AND EYE
BATH.
Work Hygienic Practices:WASH THOROUGHLY AFTER USE AND BEFORE EATING,
DRINKING, SMOKING OR USING SANITARY FACILITIES .
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
PROPOSED TLV STEL = 0.2 MG(SN)/M3, S.
OSHA PEL:0.1 MG(SN)/M3, S
ACGIH TLV:0.1 MG(SN)/M3, S
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: HARMFUL IF SWALLOWED, INHALED,
OR ABSORBED THROUGH SKIN. MATL IS EXTREMELY DESTRUCTIVE TO TISSUE
OF THE MUCOUS MEMBRANES AND UPPER RESPIRATORY TRACT, EYES & SKIN.
INHALATION MAY BE FATAL AS A R ESULT OF SPASM, INFLAMMATION AND
EDEMA OF THE LARYNX AND BRONCHI, CHEMICAL PNEUMONITIS AND PULMONARY
EDEMA.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:BURNING SENSATION, COUGHING, WHEEZING,
LARYNGITIS, SHORTNESS OF BREATH, HEADACHE, NAUSEA AND VOMITING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:EYES & SKIN: IMMED FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT
WASH BEFORE REUSE. DISCARD CONTAMD SHOES. ASSURE ADEQUATE FLUSHING
OF THE EYES BY SEPARATING THE LIDS WITH FINGERS. INHAL: REMOVE TO
FRESH AIR. IF NOT BREATHING GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. GET MD. INGEST: GET MD
IMMEDIATELY .
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER, ALCOHOL OR
POLYMER FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND PROTECTIVE
CLOTHING TO PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE AREA. WEAR NIOSH/MSHA APPRVD SCBA,
AND PLACE IN CLOSED CONTAINERS FOR DISPOSAL. VENTILATE AREA AND
WASH SPILL SITE AFTER MATE RIAL PICKUP IS COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DO NOT BREATHE VAPOR. KEEP TIGHTLY
CLOSED. STORE IN A COOL DRY PLACE.
Other Precautions:DO NOT GET IN EYES, ON SKIN OR CLOTHING. AVOID
PROLONGED OR REPEATED EXPOSURE. READILY ABSORBED THROUGH SKIN.
TOXIC. CORROSIVE.
* Physical/Chemical Properties *
HCC:C2
Appearance and Odor:COLORLESS LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF: CARBON MONOXIDE,
CARBON DIOXIDE, TIN/TIN OXIDES.
* Disposal Considerations *
Waste Disposal Methods:DISSOLVE OR MIX THE MATL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. OBSERVE ALL FEDERAL, STATE & LOCAL LAWS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:LAB COAT OR APRON.
Work Hygienic Practices:USUAL.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:WATER
Ingred Name:CESIUM (I) NITRATE (1:1)
Fraction by Wt: 0.1-1%
Ingred Name:NITRIC ACID
OSHA PEL:2 PPM;4 PPM STEL
ACGIH TLV:2 PPM;4 PPM STEL
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC:NOT APPLICABLE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:BURNS, COUGHING, IRRITATION, NAUSEA, VOMITING,
LABORED BREATHING.
Medical Cond Aggravated by Exposure:NONE.
* First Aid Measures *
INHAL:MOVE TO FRESH AIR. INGEST:DO NOT INDUCE VOMITING. GIVE
COPIOUS AMOUN TS OF WATER OR MILK.
* Fire Fighting Measures *
Extinguishing Media:WATER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:TAKE UP WITH INERT, ABSORBENT MATERIAL.
CONTAINERIZE FOR DISPOSAL. FLUSH SPILL AREA WITH WATER.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:STORE IN A CORROSION FREE AREA. KEEP
CONTAINER SEALED.
Other Precautions:NONE.
* Physical/Chemical Properties *
HCC:N1
Spec Gravity:1
Evaporation Rate & Reference:1 (BUTYL ACETATE=1)
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR, COLORLESS, ODORLESS SOLUTION.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG BASES OR STRONG REDUCING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT OR COLD.
Hazardous Decomposition Products:NO*X.
* Disposal Considerations *
Waste Disposal Methods:CORROSIVE WASTE. DISPOSE OF IN ACCORDANCE WITH
ALL FEDERAL, STATE, AND LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF EXCESSIVE DUSTS OR FIBERS PRESENT, A
NIOSH-APPROVED DUST RESPIRATOR IS RECOMMENDED. IF CONCENTRATION
EXCEEDS CAPACITY OF RESPIRATOR, USE S ELF-CONTAINED BREATHING
APPARATUS.
Ventilation:MECHANICAL (GENERAL AND/OR LOCAL EXHAUST) VENTILATION TO
MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:EYE WASH STATION, QUICK DRENCH SHOWER AND
IMPERVIOUS CLOTHING
Work Hygienic Practices:KEEP WORK AREA CLEAN OF ASBESTOS DUST.
Supplemental Safety and Health
* Product Identification *
Product ID:GASKETS
* Composition/Information on Ingredients *
Ingred Name:ASBESTOS, CHRYSOTILE
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 FIBERS/CC
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE AND CHRONIC- BREATHING OF
ASBESTOS FIBERS IN SIGNIFICANT AMOUNTS MAY PRODUCE IRREVERSIBLE
LUNG DISEASE AND CANCER. FREE FIBERS CAN CAUSE EYE AND SKIN
IRRITATION. INGESTION IS NOT LIKELY.
Explanation of Carcinogenicity:CONTAINS ASBESTOS.
Effects of Overexposure:BREATHING OF ASBESTOS FIBERS IN SIGNIFICANT
AMOUNTS MAY PRODUCE IRREVERSIBLE LUNG DISEASE AND CANCER. FREE
FIBERS CAN CAUSE EYE AND SKIN IRRITATION. INGESTION IS NOT LIKELY.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS OR EYE PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION MAY BE
MORE SUSCEPTIBLE TO THE EFFECTS OF THE SUBSTANCE.
* First Aid Measures *
First Aid:GET MEDICAL ATTENTION IF NEEDED. SKIN:WASH WITH SOAP & WATER.
INHALED:REMOVE TO FRESH AIR. PROVIDE OXYGEN/CPR IF NEEDED.
ORAL:CALL A PHYSICIA N.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
* Accidental Release Measures *
Spill Release Procedures:VACUUM FIBERS AND DUSTS, CAREFULLY, AVOIDING
DUSTING. IF SWEEPING IS USED, CONTROL DUST BY WETTING AND USE
APPROPRIATE DUST MASK.
*Handling and Storage *
Handling and Storage Precautions:STORAGE- NOT RELEVANT FOR A FINISHED
PRODUCT IN SPIRAL WOUND GASKET.
Other Precautions:DO NOT BREATHE DUST OR FIBERS. WASH THOROUGHLY AFTER
HANDLING.
* Physical/Chemical Properties *
HCC:T6
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Hazardous Decomposition Products:NONE KNOWN
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIMS BY VENT, WEAR A PROPERLY FITTED NIOSH APPRVD ORG
VAP/PARTICULATE RESP FOR PROT AGAINST INGS. WHEN SANDING/ABRADING
DRIED FILM, WEAR NIOSH APPRV D DUST/MIST RESP FOR DUST WHICH
(SUPDAT)
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPT IF EXPOS TO INGS IS
MAINTAINED BELOW APPLIC EXPOS LIMS. REFER TO OSHA STDS (SUPP DATA)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC:PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN EXPOS
TO EXTREME HEAT. EXPLO HAZ:PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT
BE IMMED APPARENT. OBTAIN MED ATTN. RESP PROT:MAY BE GENERATED
* Product Identification *
* Composition/Information on Ingredients *
ACGIH TLV:ASPHYXIANT
Fraction by Wt: 6%
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:LACOLENE; (LIGHT ALIPHATIC HC SOLVENT). VP:2.
Fraction by Wt: 8%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (TALC)
Fraction by Wt: 3%
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:CARBONIC ACID, CALCIUM SALT (1:1); (CALCIUM CARBONATE).
Fraction by Wt: 3%
OSHA PEL:SEE INGREDIENT
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
Fraction by Wt: 2%
Ingred Name:SUPDAT:OVEREXP TO SOLV INGS MAY CAUSE ADVERSE EFTS TO
Ingred Name:OTHER PREC:PROCS. HEAT FROM SUNLIGHT, RADIATORS, STOVES,
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPOS MAY BE BY INHAL &/OR SKIN/EYE
CONT, DEPENDING ON CNDTNS OF USE. TO MIN EXPOS, FOLLOW RECS FOR
PROPER USE, VENT & PPE. ACUTE:IRRIT OF EYES, SKIN & RESP SYS. MAY
CAUSE NERV SYS DEPRESS. EXTREME OV EREXP MAY RSLT IN UNCON & POSS
DEATH. HDCH, DIZZ, NAUS & LOSS OF COORD ARE INDICATIONS OF
EXCESSIVE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:EXPOS TO VAPS/SPRAY MIST. REDNESS &
ITCH/BURNING SENSATION MAY INDICATE EYE/EXCESSIVE SKIN EXPOS.
CHRONIC:PRLNG & RPTD EXPOS TO HEXANE MAY CAUSE DMG TO NERVE TISS OF
ARMS & LEGS (PERIPHERAL N EUROPATHY), RESULTING IN MUSCULAR WEAK &
LOSS OF SENSATION. THIS EFT MAY BE INCR BY PRESENCE OF METHYL ETHYL
(SUPP DATA)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
* First Aid Measures *
First Aid:INHAL:REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM &
QUIET. SKIN:WASH AFFECTED AREA THOROUGHLY W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING & LAUNDER BEFORE RE-USE. EYES:FLUSH W/LARGE
INGEST:SEEK MEDICAL ATTENTION.
* Fire Fighting Measures *
Lower Limits:0.7%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL FOAM.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER SPRAY MAY BE INEFT. IF WATER IS USED, FOG NOZZ ARE PREF.
WASTE MAY BE USED TO COOL CLSD CNTNRS TO (SUPDAT)
Unusual Fire/Explosion Hazard:EXTREMELY FLAMM. CLSD CNTNRS MAY EXPLODE
WHEN EXPOS TO EXTREME HEAT. APPLICATION TO HOT SURFS REQS SPECIAL
PRECS. DURING EMER CNDTNS OVEREXP TO DECOMP (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE &
REMOVE W/INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DOL STOR CATEGORY-1A. CONTENTS ARE
EXTREMELY FLAMM. KEEP AWAY FROM HEAT, SPKS & OPEN FLAME. VAPS WILL
ACCUM READILY & MAY IGNITE EXPLOSIVELY.
Other Precautions:DURING USE & UNTIL ALL VAPS ARE GONE:KEEP AREA
VENTED; DO NOT SMOKE; EXTING ALL FLAMES, PILOT LIGHTS & HEATERS;
TURN OFF STOVES, ELEC TOOLS & APPLIANCES & ANY OTHER SOURCES OF
* Physical/Chemical Properties *
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF METALS IN INGREDIENTS.
* Disposal Considerations *
Waste Disposal Methods:WASTE FROM THESE PRODUCTS MAY BE HAZARDOUS AS
IGNITABILITY TO DETERM APPLIC EPA HAZ WASTE NUMBER. DO NOT INCIN.
DEPRESSURIZE CNTNR. DISP O F I/A/W FED, STATE & LOC REGS
REGARDINGPOLLUTION.
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF SOOT IS FORMED, USE NIOSH APPROVED
RESPIRATOR.
Ventilation:LOCAL EXHAUST: AIR HOOD; MECHANICAL: FAN.
Other Protective Equipment:APPROPRIATE TO AVOID PROLONGED CONTACT.
Work Hygienic Practices:WASH HAND BEFORE EATING, DRINKING OR SMOKING.
TRAIN PERSONNEL IN THE SAFE HANDLING OF THIS PRODUCT.
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:LEAD PEROXIDE
Other REC Limits:NONE SPECIFIED
Ingred Name:LEAD OXIDE
Fraction by Wt: 6%
Other REC Limits:NONE SPECIFIED
Ingred Name:THE EXPOSURE LIMITS ARE BASED ON DUST PARTICLES. . IN THIS
PRODUCT THE LEAD DIOXIDE/OXIDE PARTICLES ARE WETTED OUT
Other REC Limits:NONE SPECIFIED
Ingred Name:THEREFORE AIRBORNE PARTICLES WILL NOT RESULT FROM NORMAL
USE.
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: WEAKNESS, STUPOR. CHRONIC:
KIDNEY DAMAGE, ANEMIA, REPRODUCTIVE DEFECTS.
Effects of Overexposure:HEADACHE, MUSCLE AND JOINT PAIN, NEUROMUSCULAR
DYSFUNCTION.
Medical Cond Aggravated by Exposure:ANEMIA, KIDNEY DISEASE, PREGNANCY.
* First Aid Measures *
First Aid:INGESTION: INDUCE VOMITING, CONSULT A PHYSICIAN AT ONCE. EYE
CONTACT: FLUSH WITH LARGE AMOUNT OF WATER AND CONTACT PHYSICIAN.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:FOAM, DRY CHEMICAL, CO2, WATER.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS WITH
FULL FACEPIECE, IN CONFINED AREAS.
Unusual Fire/Explosion Hazard:FIRE HAZARD EXISTS IF CONTACT WITH
OXIDIZABLE MATERIALS AT HIGH TEMPERATURES OCCURS.
* Accidental Release Measures *
Spill Release Procedures:SCOOP UP AND TRANSFER TO A SAFETY CONTAINER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL DRY AREA. KEEP
CONTAINERS CLOSED.
* Physical/Chemical Properties *
HCC:F4
Melt/Freeze Pt:M.P/F.P Text:LIQ@RM TEMP
Vapor Pres:NIL
Evaporation Rate & Reference:NIL
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BROWN PASTE; OILY ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZABLE MATERIALS.
Stability Condition to Avoid:HIGH HEAT.
Hazardous Decomposition Products:LEAD OXIDE DUST AND ORGANICS.
* Disposal Considerations *
Waste Disposal Methods:RETURN TO SMELTER FOR RECLAMATION OR REACT WITH
BASE AND DISPOSE ACCORDING TO FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROVED FOR
EXPOSURE OF CONCERN .USE NIOSH APPROVED MIST RESPIRATOR WHEN SPRAY
OCCURS (MFR).
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW LEVELS OF CONCERN .
Other Protective Equipment:NONE
Work Hygienic Practices:N/K
Supplemental Safety and Health
N/K
* Product Identification *
CAGE:INORG
CAGE:INORG
* Composition/Information on Ingredients *
Ingred Name:SILIC ACID,POTASSIUM SALT (POTASSIUM SILICATE)
Other REC Limits:
OSHA PEL:
ACGIH TLV:
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SPRAY MIST MAY DAMAGE RESPIRATORY
TRACT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:IRRITATION.INHALATION:SPRAY MIST MAY
DAMAGE RESPIRATORY TRACT.SKIN:N/K.INGEST:.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
MEDICAL ATTENTION.SKIN:.INHALATION:REMOVE TO FRESH AIR.SUPPORT
BREATHING (GIVE OXYGEN/ARTIFICIAL RESPIRATION) .INGEST ION:GET
MEDICAL ATTENTION IMMEDIATELY .
* Fire Fighting Measures *
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:FLAMMABLE HYDROGEN GAS MAY BE PRODUCED
UPON PROLONGED CONTACT WITH METALS SUCH AS ALUMINUM,TIN,LEAD AND
ZINC.
* Accidental Release Measures *
TO SEWER WITH PLENTY OF WATER.LARGE QUANTITIES:ISOLATE.DIKE AND
STORE MATERIAL IF POSSIBLE.
Neutralizing Agent:DILUTE ACID.
*Handling and Storage *
Handling and Storage Precautions:
Other Precautions:NONE
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:
Decomp Temp:Decomp Text:
Spec Gravity:1.2-1.7 H*2O=1
Solubility in Water:COMPLETE
Appearance and Odor:VISCOUS LIQUID,LIGHT GRAY,HAZY,ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
GELS WHEN MIXED WITH ACID.METALS SUCH AS ALUMINUM,TIN,LEAD AND ZINC.
Stability Condition to Avoid:
Hazardous Decomposition Products:NONE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .NEUTRALIZE WITH DILUTE ACID
AND LANDFILL SOLIDS.FLUSH NEUTRAL LIQUID TO SEWER WITH PLENTY OF
WATER.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:PROTECTIVE CLOTHING, SAFETY SHOWER, EYE
BATH.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:DICHLOROMETHANE (METHYLENE CHLORIDE) (SUSP HUMAN CARC BY
Ingred Name:ACETIC ACID, DIAZO-, ETHYL ESTER, ETHYL DIAZOACETATE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:TOXIC. HARMFUL BY INHALATION, IN
CONTACT W/SKIN & IF SWALLOWED. POSSIBLE RISK OF IRREVERSIBLE
EFFECTS. POSSIBLE CARCINOGEN/MUTAGEN. NEUROLOGICAL HAZARD.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:TOXIC. HARMFUL BY INHALATION, IN CONTACT W/SKIN
& IF SWALLOWED. POSSIBLE RISK OF IRREVERSIBLE EFFECTS. POSSIBLE
CARCINOGEN/MUTAGEN. NEUROLOGICAL HAZARD.
* First Aid Measures *
WASH W/SOAP & COPIOUS AMOUNTS OF WATER. INHALATION: REMOVE TO FRESH
AIR. GIVE CPR/OXYGEN IF NEEDED. INGESTION: WASH OUT MOUTH W/WATER
PROVIDED PERSON IS CONSCIOUS. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY.
Fire Fighting Procedures:WEAR SCBA & PROTECTIVE CLOTHING. USE WATER
SPRAY TO COOL CONTAINERS.
Unusual Fire/Explosion Hazard:FLAMMABLE LIQUID. MAY EXPLODE WHEN
HEATED. EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE AREA. WEAR SCBA, RUBBER BOOTS & HEAVY
CONTAINERS USING NON-SPARKING TOOLS & TRANSPORT OUTDOORS. VENTILATE
AREA & WASH SITE AFT ER MATERIAL PICKUP IS COMPLETE.
*Handling and Storage *
Handling and Storage Precautions:KEEP TIGHTLY CLOSED, AWAY FROM
COMBUSTIBLE MATERIALS, HEAT, SPARKS & OTHER IGNITION SOURCES.
REFRIGERATE.
Other Precautions:AVOID CONTACT W/EYES, SKIN & CLOTHING. AVOID
PROLONGED/REPEATED EXPOSURE.
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:-7.6F
Appearance and Odor:YELLOW LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, HEAT SENSITIVE.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME & OTHER IGNITION
SOURCES.
Hazardous Decomposition Products:COMBUSTION: CO, CO2, NITROGEN OXIDES.
* Disposal Considerations *
Waste Disposal Methods:DISSOLVE/MIX THE MATERIAL W/A COMBUSTIBLE
SOLVENT & BURN IN A CHEMICAL INCINERATOR EQUIPPED W/AFTERBURNER &
SCRUBBER. DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED AT LOW LEVELS. WEAR NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST OR GENERAL DILUTION VENTILATION SYSTEM.
Other Protective Equipment:NONE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PATIENTS WHO HAVE PRLNGD COMA/CONVULSIONS MAY HAVE IRREVERSIBLE
BRAIN DMG. MASSIVE DOSES MAY CAUSE INTRAVASCULAR HEMOLYSIS.
CHRONIC: EYE : PRLNGD/RPTD CONT MAY CAUSE CONJUNCT. SKIN:
RPTD/PRLNGD CONT MAY CAUSE DERM. INHAL: RPTD EXPOS MAY CAUSE (ING
4)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:1,2-PROPANEDIOL; (PROPYLENE GLYCOL)
Ingred Name:DISTILLED WATER
Ingred Name:AMMONIUM COMPOUND (CASEINATE)
Fraction by Wt: 7.2%
Ingred Name:SUPP DATA: NYSTAGMUS, LYMPHOCYTOSIS AND UNCONSCIOUSNESS.
Ingred Name:FIRST AID PROC:IF BRTHG HAS STOPPED, PERFORM ARTF RESP.
KEEP PERSON WARM AND AT REST. GET MED ATTN IMMED. INGEST:(ING 6)
Ingred Name:ING 5:IF VICTIM IS CONSCIOUS, IMMED GIVE 2-4 GLASSES OF
H*2O & INDUCE VOMIT BY TOUCHING FINGER TO BACK OF THROAT.(ING 7)
Ingred Name:ING 6: GET MEDICAL ATTENTION IMMEDIATELY.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITANT. ACUTE: DIRECT CONT MAY
CAUSE REDNESS/IRRIT. SKIN: IRRITANT. ACUTE: IRRIT/DRYNESS MAY OCCUR
FROM DEFATTING ACTION OF LIQ. INHAL: IRRITANT. ACUTE: INHAL OF
SUBSTANCE MAY CAUSE RESP/THROA T IRRIT. HIGH VAP CONC MAY CAUSE CNS
DEPRESS W/HDCH, DIZZ/DROW. INGEST: ACUTE: INITIAL SYMP IN MASSIVE
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
THOSE OF ALCOHOL INTOXICATION. SYMP SOON PROGRESS TO VOMIT,
CYANOSIS, HDCH, TACHYPNEA, TACHYCARDIA, HYPOTENSION, PULM EDEMA,
MUSCLE TENDERNESS, STUPOR,ANURIA, PROSTRATION & UNCON
W/CONVULSIONS. HYPOGLYCEMIA MAY OCCUR. DEATH MAY OCCUR W/IN FEW
HOURS FROM RESP (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:EYES: WASH EYES IMMED W/LRG AMTS OF H*2O, OCCASIONALLY
CHEM REMAINS. IF REDNESS/IRRIT PERSISTS, GET MED ATTN. SKIN: REMOVE
CONTAM CLT HG & SHOES. WASH AFFECTED AREAS W/SOAP/MILD DETERGENT &
MIN). GET MED ATTN. INHAL: REMOVE FROM EXPOS AREA TO FRESH AIR
IMMED.(ING 5)
* Fire Fighting Measures *
Lower Limits:2.6%
Extinguishing Media:WATER FOG, ALCOHOL FOAM, CARBON DIOXIDE, DRY
CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROT
EQUIP . NO ACUTE HAZ. MOVE CONTAINER FROM FIRE AREA IF POSSIBLE.
AVOID BREATHING VAPORS; KEEP UPWIND.
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:SHUT OFF IGNITION SOURCES. STOP LEAK IF YOU
CAN DO IT WITHOUT RISK. FOR SMALL SPILLS, TAKE UP WITH SAND OR
OTHER ABSORBENT MEDIUM AND PLACE INTO CONTAINERS FOR LATER
DISPOSAL. NO SMOKING, FLAMES OR FL ARE IN HAZ AREA.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM IGNITION SOURCES.
PROTECT FROM HIGH HEAT. KEEP CONTAINERS CLOSED WHEN NOT IN USE.
Other Precautions:NOT APPLICABLE.
* Physical/Chemical Properties *
HCC:N1
Spec Gravity:1.0
Appearance and Odor:ODORLESS, COLORLESS, HYGROSCOPIC, VISCOUS LIQUID
WITH SLIGHTLY ACID TASTE.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ALKALI METALS (FORMS HYDROGEN GAS), ATTACKS PLASTICS.
Stability Condition to Avoid:MAY BE IGNITED BY HEAT OR FLAMES.
CONTAINER MAY EXPLODE IN HEAT FROM FIRE. VAPOR EXPLOSION HAZARD
INDOORS.
Hazardous Decomposition Products:DECOMPOSES WHEN HEATED TO FORM
PEROXIDES AND PROPIONALDEHYDES.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC
VAPORS/MIST AS REQUIRED IF ABOVE PEL/TLV OR SCBA IN AN ENCLOSED
AREA.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER,WORK
CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS.
* Product Identification *
Product ID:ACETONE,TECHNICAL
Preparer's Name:C.A. EISENHARD
* Composition/Information on Ingredients *
Ingred Name:ACETONE (SARA III)
Ingred Name:BENZENE (SARA III)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATION OF
EYES,SKIN,RESPIRATORY OR G.I.TRACTS;CNS EFFECTS LIKE
HEADACHE,DIZZINESS,NAUSEA,VOMITING AND POSSIBLE
UNCONSCIOUSNESS;REDNESS OR BURNS OF EYES/SKIN POSSIBLE.CHRONIC:NO
SPECIFIC INFO RMATION IS AVAILABLE;MAY CAUSE DRYING OF
SKIN,DEFATTING OR DERMATITIS,CNS DEPRESSION,LIVER OR KIDNEY INJURY.
Explanation of Carcinogenicity:DATA PER MSDS
Effects of Overexposure:SEE HEALTH HAZARDS DATA.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
* First Aid Measures *
First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
SKIN:REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER. IF
IRRITATION PERSISTS, GET MEDICAL ADVICE. INGESTION:DO NOT INDUCE
VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET IMMEDIATE
MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:2
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND
FULL FACE-PIECE SELF-CONTAINED BREATHING APPARATUS. COOL FIRE
EXPOSED CONTAINERS WITH WATER SPRAY. CONTAIN RUNOFF.
Unusual Fire/Explosion Hazard:HEAT FROM FIRE MAY CAUSE BUILD UP OF
HAZARDOUS VAPOR PRESSURE IN CLOSED CONTAINERS.
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;REMOVE ALL
IGNITION SOURCES;CONTAIN FREE MATERIAL IF POSSIBLE;USE SUITABLE
INERT ABSORBENT MATERIAL AND RECOVER FOR PROPER DISPOSAL IN AN
APPROVED CONTAINER.
Neutralizing Agent:NOT APPLICABLE.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT
CONTAINERS FROM PHYSICAL DAMAGE.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE MIST. AVOID
PROLONGED OR REPEATED BREATHING OF VAPOR. AVOID CONTACT WITH EYES.
USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.DO
NOT CUT,GRIND,WEL D OF DRILL ON OR NEAR THE CONTAINER.
* Physical/Chemical Properties *
HCC:F2
Vapor Density:2
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID, SWEET ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
OTHER UNIDENTIFIED COMPONENTS IN BLACK SMOKE.
* Disposal Considerations *
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES.DISPOSAL MUST BE MADE
IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE IN WELL VENTILATED AREA. RESPIRATORY MASK IS
NOT REQUIRED, BUT IF USED, SHOULD BE TYPE FOR ORGANIC VAPORS. USE
NIOSH/ MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN
.
Ventilation:LOCAL EXHAUST: PREFERABLE. MECH: ACCEPTABLE.
Other Protective Equipment:AS REQUIRED BY YOUR COMPANY.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:(2-BUTANONE; (METHYL ETHYL KETONE)
Fraction by Wt: <2%
Ingred Name:ACETONE
Fraction by Wt: <4%
Ingred Name:ETHANE, 1,1,1-TRICHLORO-; (1,1,1-TRICHLOROETHANE)
Fraction by Wt: <4.5%
Ozone Depleting Chemical:1
Ingred Name:SOLVENT NAPHTHA; (PETROLEUM NAPHTHA SOLVENT)
Fraction by Wt: <2%
Ingred Name:ETHANE, 1,1,2-TRICHLORO-1,2,2-TRIFLUORO-;
(1,1,2-TRICHLORO-1,2,2-TRIFLUOROETHANE)
Ozone Depleting Chemical:1
Ingred Name:METHANE, DICHLORODIFLUORO-; (DICHLORODIFLUOROMETHANE)
Ozone Depleting Chemical:1
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: LT-HEAD, SHORT OF BRTH.
INGEST: UNLIKELY AS AN AEROSOL PROD. SKIN: MAY CAUSE DRYNESS. EYES:
MAY CAUSE TEMPORARY IRRIT/CONJ. CHLOROFLUOROCARBON MATLS HAVE PRDCD
SENSIT OF MYOCARDIUM TO EP INEPHRINE IN LAB ANIMALS & COULD HAVE
SIMILAR EFT IN HUMANS. ADRENOMIMETICS (E.G., EPINEPHRINE) MAY (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: BE CONTRAINDICATED EXCEPT FOR
LIFE-SUSTAINING USES IN HUMANS ACUTELY OR CHRONICALLY EXPOSED TO
CFC'S .
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. IF NOT BREATHING GIVE
MOUTH-TO-MOUTH RESUSCITATION. IF BREATHING DIFFICULT, GIVE OXYGEN.
CALL PHYSICIAN. INGEST: (NOT LIKELY AS AN AEROSOL PRODUCT). CALL MD
IMMED . S KIN: WASH AREA WITH DETERGENT AND WATER. EYES: IMMED
* Fire Fighting Measures *
Flash Point:NON FLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:COMPRESSED GAS IN AEROSOL MAY EXPLODE
UNDER FIRE CONDITIONS. THERMAL DECOMP PROD MAY INCL HCL, CHLORIDES,
FLUORIDES AND PHOSGENE .
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. CNTN SPILL;
IF CONTAINER IS DAMAGED TRANSFER TO CLOSED LINED METAL, GLASS/
PLASTIC CONTAINER. USE ABSORBANT MATERIAL TO COLLECT AND CONTAIN
FOR SALVAGE OR DISPOSAL.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:DO NOT STORE WHERE TEMPERATURE EXCEEDS
WELDING ARCS.
Other Precautions:NO SMOKING IN AREA OF USE. DO NOT USE IN GENERAL
VICINITY OF ARC WELDING, OPEN FLAMES/HOT SURF. HEAT &/OR UV RADIA
MAY CAUSE FORM OF HCL, CHLORIDES, FLUORIDES AND PHOSGENE .
* Physical/Chemical Properties *
Vapor Density:2.9
Spec Gravity:1.4
Evaporation Rate & Reference:RAPID
Solubility in Water:SLIGHTLY
Appearance and Odor:MILDLY WHITE, CHARACTERISTIC ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:OPEN FLAMES & WELDING ARCS. DO NOT STORE
Hazardous Decomposition Products:HIGH TEMPERATURES OR OPEN FLAME MAY
CAUSE DECOMP & GIVE OFF TOXIC GASES. HCL, CHLORIDES, FLUORIDES &
PHOSGENE .
* Disposal Considerations *
Waste Disposal Methods:AXEL PLASTICS SUGGESTS THAT ALL LOC, STATE AND
FEDERAL REGULATIONS CONCERNING HEALTH AND POLLUTION BE REVIEWED TO
DETERMINE APPROVED DISPOSAL PROCEDURES. CONTACT AXEL PLASTICS IF
THERE ARE ANY DISPOSA L QUESTIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:UTILIZE NIOSH/MSHA APPROVED RESPIRATORY
PROTECTION DEVICES FOR NUISANCE DUST.
Ventilation:UTILIZE LOCAL EXHAUST TO KEEP AIRBORNE CONCENTRATION BELOW
TLV.
Other Protective Equipment:ARM SLEEVES OR BARRIER CREAMS MAY BE USEFUL
IN THE PREVENTION OF DERMATITIS.
Work Hygienic Practices:MAINTAIN NORMAL HOUSEKEEPING PROCDURES FOR
NUISANCE DUST.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Product ID:AOF
* Composition/Information on Ingredients *
Ingred Name:ALUMINUM OXIDE (2:3); (ALUMINUM OXIDE) (SARA III)
Ingred Name:TITANIUM OXIDE
Fraction by Wt: 2.7%
Ingred Name:SILICON DIOXIDE, AMORPHOUS
Fraction by Wt: 0.5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MAGNESIUM OXIDE
Fraction by Wt: 0.2%
Ingred Name:IRON (III) OXIDE (IRON OXIDE)
Fraction by Wt: 0.1%
ACGIH TLV:5 MG(FE)/M3 FUME, B2
Ingred Name:CALCIUM OXIDE
Fraction by Wt: 0.1%
OSHA PEL:5 MG/M3
ACGIH TLV:2 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPOS TO EXCESS AIRBORNE CONC MAY
RESULT IN ACUTE RESP DISORDERS. INDIVIDUALS WITH IMPAIRED PULMONARY
FUNCTION SHOULD NOT BE SUBJECTED TO EXCESS AIRBORNE CONC. SYMPTOMS
OF EXCESS EXPOS MIGHT INCL DEPO SITS OF MATL IN EYES, EARS, NASAL
PASSAGES AND IRRIT OF THE MUCOUS MEMBRANES, EYE AND RESP TRACT.
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:IRRITATION OF THE SKIN MAY ALSO OCCUR
DUE TO MECHANICAL/CHEMICAL ACTION.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:INHAL:REMOVE FROM EXPOSURE. EYE/SKIN:IRRIGATE WITH COPIOUS
INGEST:CALL MD. IMMEDIATELY .
* Fire Fighting Measures *
Extinguishing Media:USE EXTINGUISHING MEDIA SUITABLE FOR SURROUNDING
FIRE .
Fire Fighting Procedures:NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
* Accidental Release Measures *
Spill Release Procedures:NORMAL PRECAUTIONS FOR INERT OR NUISANCE DUSTS
AND PARTICULATES.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:USE HANDLING PROCEDURES WHICH WILL
LIMIT EXPOSURE TO EXCESSIVE AIRBORNE DUST.
* Physical/Chemical Properties *
Vapor Pres:ESSEN 0
Solubility in Water:INSOLUBLE
Appearance and Odor:LIGHT TO DARK BROWN, NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE WITH HOT CHLORINATED RUBBER.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN COMPLIANCE WITH ALL FEDERAL,
STATE, AND LOCAL LAWS AND REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NO SPECIAL REQUIREMENTS UNDER ORDINARY
CONDITIONS OF USE AND WITH ADEQUATE VENTILATION. USE NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NO SPECIAL REQUIREMENTS UNDER ORDINARY CONDITIONS OF USE
AND WITH ADEQUATE VENTILATION.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:GOOD PERSONAL HYGIENE PRACTICES SHOULD ALWAYS
BE FOLLOWED.
Supplemental Safety and Health
FIRE FIGHT PROC: USED TO FLUSH SPILLS AWAY FROM EXPOS. PREVENT RUNOFF
FROM FIRE CTL/DILUTION FROM ENTERING STREAMS/DRINKING WATER SUPPLY.
FIRST AID PROC: INTO LUNGS MAY CAUSE CHEM PNEUMIT. TREAT APPRO P.
* Product Identification *
* Composition/Information on Ingredients *
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CONTAINS THREE OR MORE OF THE FOLLOWING BASE OILS
(INGREDIENTS 3-6)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED (SEV)
PARAFFINIC; (DISTIL (PETROLEUM), HYDROTREATED LIGHT PARAFFINIC)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATE, SOLVENT DDEWAXED
(SEVERE), HEAVY PARAFFINIC
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED
(SEVERE),HEAVY PARAFFINIC
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED (SEV)
LIGHT NAPHTHENIC; (DISTIL (PETRO), HYDROTREATED LIGHT NAPHTHENIC)
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:2-PROPENOIC ACID, 2-METHYL-, DODECYL ESTER, POLYMER WITH
METHYL 2-METHYL-2-PROPENOATE & TETRADECYL 2-METHYL-2-PROPENOATE
Fraction by Wt: <3%
OSHA PEL:N/K
ACGIH TLV:N/K
RETARDANT TREATED SAWDUST, DIATOMACEOUS EARTH, ETC. (ING 9)
Ingred Name:ING 8: SHOVEL UP & DISPOSE OF AT AN APPROP WASTE DISP
Ingred Name:ING 9: PRODUCT CHARACTERISTICS AT TIME OF DISPOSAL.
Ingred Name:WASTE DISP METH: CAN BE DISP OF AT ANY GOVERNMENT APPRVD
REGS & CONSIDERATIONS OF PROD CHARACT AT TIME OF DISP.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INGEST: SLIGHTLY TOX. SKIN:
SLIGHTLY TOX. MAY CAUSE SLIGHT IRRIT ON PRLNG/RPTD CONT. SEVERELY
SOLV REFINED & SEVERELY HYDROTREATED MINERAL BASE OIL HAVE BEEN
TESTED AT MOBIL ENVIRONMENTAL & HLT H SCIENCES LAB BY DERMAL
HIGHER (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: THAN THOSE EXPECTED DURING NORMAL
INDUSTRIAL EXPOSURE. CHRONIC: BASE OILS IN THIS PRODUCT ARE
SEVERELY SOLVENT REFINED AND/OR SEVERELY HYDROTREATED. PROLONGED
REPEATED SKIN CONTACT WITH LOW VISCOSITY MATERIALS MAY DEFAT THE
SKIN RESULTING IN POSSIBLE IRRITATION AND DERMATITIS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
AREAS W/SOAP & WATER. HIGH PRESS ACCIDENTAL INJECTION THRU SKIN
REQUIRES IMMED MED ATTN FOR POSS INCISION, IRRIGATION
&/DEBRIDEMENT. INHAL: NOT EXPECTED TO BE A PROBLEM. REMOVE TO
FRESH AIR. SUPPORT BRTHG (GIVE OXYGEN/ARTF RESP) . INGEST: DO NOT
INDUCE VOMIT. ADMIN VEGETABLE OIL. GET MED ASSIST. NOTE TO MD:
MATL, IF ASPIRATED (SUP DAT)
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:0.6%
Upper Limits:7.0%
Extinguishing Media:CRBON DIOXIDE, FOAM, DRY CHEMICAL, AND WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER/FOAM MAY CAUSE FROTHING. USE WATER TO KEEP FIRE-EXPOSED
CONTRS COOL. WATER SPRAY MAY BE (SUP DAT)
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:REPORT SPILLS AS REQUIRED TO APPROP AUTH. US
COAST GUARD REGS REQUIRE IMMED REPORTING OF SPILLS THAT COULD REACH
ANY WATERWAY INCL INTERMITTENT DRY CREEKS. REPORT SPILL TO COAST
(ING 8)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID PROLONGED/REPEATED CONTACT THAT
COULD DEFAT SKIN. FOR INDUSTRIAL USE ONLY. NOT INTENDED OR SUITABLE
FOR USE IN OR AROUND HOUSEHOLD/DWELLING.
Other Precautions:EMPTY CONTAINERS MAY CONTAIN PRODUCT RESIDUE,
INCLUDING FLAMMABLE OR EXPLOSIVE VAPORS. DO NOT CUT, PUNCTURE/WELD
ON/NEAR CONTAINER. ALL LABEL WARNINGS AND PRECAUTIONS MUST BE
OBSERVED UNTIL CONTAINER HAS BEEN THOROUGHLY CLEANED/DESTROYED.
* Physical/Chemical Properties *
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER LIQUID, WITH MILD ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:EXTREME HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:PROD SUITABLE FOR BURNING IN ENCLSD, CONTROLLED
BURNER FOR FUEL VALUE/DISP BY SUPERVISED INCIN. SUCH BURNING MAY BE
LIMITED PURSUANT TO RESOURCE CONSERVATION & RECOVERY ACT. IN ADDN,
PROD SUITABLE FOR PROCESSING BY APPRVD RECYCLING FACILITY/ (ING
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF VAPORS ARE PRESENT, USE NIOSH/MSHA APPROVED
RESPIRATOR FOR ORGANIC VAPORS, AIR-LINE RESPIRATOR OR A
SELF-CONTAINED BREATHING APPARATUS.
Ventilation:USE ADEQUATE VENTILATION.
Other Protective Equipment:WEAR PROT CLTHG TO PVNT RPTD/PRLNGD CONTACT.
EYE WASH STATION AND SAFETY SHOWER SHOULD BE NEAR WORK AREA.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
WASTE DISP METH:SAFEGUARDS UNTIL CONTAINER IS CLEANED, RECONDITIONED,
OR DESTROYED. EYE PROT:AND FULL LENGTH FACE SHIELD .
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:NON-HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:CONTACT IS PAINFUL AND
IRRITATING. SKIN:PROLONGED OR REPEATED CONTACT CAUSES IRRITATION.
INHALATION:MIST CAUSED BY MANUFACTURING OPERATIONS IRRITATES NASAL
PASSAGES. CHRONIC:CHRONIC EFFECTS HAVE NOT BEEN ESTABLISHED.
UNNECESSARY EXPOSURE TO THIS PRODUCT OR ANY CHEMICAL SHOULD BE
AVOIDED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:MEDICAL CONDITIONS AGGRAVATED BY
OVEREXPOSURE TO THIS PRODUCT HAVE NOT BEEN ESTABLISHED.
* First Aid Measures *
MINUTES. SKIN:WASH OFF WITH WATER. REMOVE CONTAMINATED CLOTHING AND
CLEAN BEFORE REUSE. INHALATION:IF VAPORS OR MIST CAUSE IRRITATION
OR DIS TRESS, REMOVE TO FRESH AIR. INGESTION:CONSULT PHYSICIAN
IMMEDIATELY.
* Fire Fighting Measures *
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, FOAM, OR WATER FOG.
CLASS BC, ABC FIRE EXTINGUISHER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
* Accidental Release Measures *
Spill Release Procedures:CONTAIN ALL SPILLS AND LEAKS TO PREVENT
DISCHARGE INTO ENVIRONMENT. SMALL SPILLS:SOAK UP WITH ABSORBENT,
SHOVEL INTO WASTE CONTAINER, FLUSH AREA WITH WATER. LARGE
SPILLS:RECOVER LIQUID FOR REPROCESSIN G OR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID OVERHEATING OR FREEZING. DO NOT
USE NITROSATING AGENTS WITH PRODUCT SINCE NITROSAMINES MAY FORM.
Other Precautions:SOME NITROSAMINES HAVE BEEN SHOWN TO BE CARCINOGENIC
IN LAB ANIMAL TESTS. SPILLED MATERIAL IS SLIPPERY. IF INGESTED,
CALL A PHYSICIAN.
* Physical/Chemical Properties *
Vapor Density:LTR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHYL ETHER.
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NITROUS OXIDES AND AMMONIACAL VAPORS.
* Disposal Considerations *
Waste Disposal Methods:RECOVER MATL/DISP (INCIN IS PREF) IN ACCORD
W/ALL APPLIC FED, STATE & LOC REGS. MATL COLLECTED W/ABSORB MAY BE
DISP IN PERMITTED LANDFILL IN ACCORD W/FED, STATE & LOC REGS. EMPTY
CNTNRS MAY RETAIN VAP /PROD RESIDUE. OBSERVE ALL LABELED (SUPP
DATA)
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:AS REQUIRED
Ventilation:LOCAL EXHAUST
Work Hygienic Practices:WASH AFTER USE. REMOVE/LAUNDER CONTAMINATED
CLOTHING BEFORE REUSE. DON'T CONSUME FOOD/BEVERAGE WHERE PRODUCT IS
USED.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:DICK KARBO
CAGE:KMADD
CAGE:KMADD
* Composition/Information on Ingredients *
Ingred Name:NON-HAZARDOUS FOR INGREDIENTS
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED CONTACT W/SKIN/EYES CAN
CAUSE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
* First Aid Measures *
First Aid:EYES: FLUSH IMMEDIATELY W/WATER. SKIN: WASH AFFECTED AREA
W/SOAP & WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
* Accidental Release Measures *
Spill Release Procedures:SMALL: WIPE UP & STORE WIPERS IN UNDERWRITERS
APPROVED CONTAINERS. LARGE: SCOOP MATERIAL INTO SEALABLE
CONTAINERS. WIPE UP REMAINDER & STORE WIPERS IN UNDERWRITERS
APPROVED CONTAINERS.
*Handling and Storage *
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS.
Other Precautions:AVOID CONTACT W/SKIN, EYES & CLOTHING.
* Physical/Chemical Properties *
Evaporation Rate & Reference:SLOWER THAN WATER
Solubility in Water:INSOLUBLE
Appearance and Odor:OILY
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
BY DGSC-STF.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:THORIUM (NAT)
* Hazards Identification *
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
* First Aid Measures *
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
* Fire Fighting Measures *
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
* Accidental Release Measures *
*Handling and Storage *
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
* Physical/Chemical Properties *
HCC:A2
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-IN ACCORDANCE WITH
DOD REGULATIONS AND FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF HIGH VAPOR CONCENTRATION IS EXPECTED, USE
RESPIRATOR APPROVED FOR ORGANIC VAPORS.
Ventilation:IN CONFINED AREA, MECHANICAL VENTILATION MAY BE REQUIRED TO
KEEP LEVELS BELOW MANDATED STANDARDS.
Other Protective Equipment:BODY COVERING WORK CLOTHES
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
PETROLEUM DISTILLATES.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, SOLVENT-REFINED HEAVY
PARAFFINIC, LUBRICATING OIL BASE STOCK
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:ANTIOXIDANT
Ingred Name:DETERGENT INHIBITOR (CONTAINS ZINC DIALKYLDITHIOPHOSPHATE)
Ingred Name:VI IMPROVER (TYPE NOT SPECIFIED)
Ingred Name:POUR POINT DEPRESSANT
Fraction by Wt: 0-1%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY IRRITANT.
MISTS >TLV MAY CAUSE CHEMICAL PNEUMONITIS. EYES: LOW TEMPORARY
IRRITANT. INGESTION: LOW TOXICITY. GASTROINTESTINAL IRRITANT. SKIN:
SUBCUTANEOUS/INTRAMUSCULAR MAY CAUS E IRRITATION, ERYTHEMA, EDEMA.
PROLONGED/FREQUENT CONTACT MAY CAUSE DERMATITIS/FOLLICULITIS
W/SLIGHT IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DROWSINESS, DIZZINESS, HEADACHE,
NAUSEA, DIARRHEA, INTESTINAL CRAMPS, DRYING/CRACKING OF SKIN
* First Aid Measures *
First Aid:INHALATION: REMOVE FROM EXPOSURE & PROVIDE SUPPORT IF
NECESSARY. SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/LARGE VOLUMES
OF WATER. INGESTION: INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN
ALL CASES. NOT ES TO PHYSICIAN: LARGE QUANTITIES: LAVAGE MAY STILL
BE CONSIDERED. SUBCUTANEOUS INJECTION REQUIRES PROMPT SURGICAL
DEBRIDEMENT.
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER FOG
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:WATER MAY CAUSE FROTHING.
* Accidental Release Measures *
Spill Release Procedures:REMOVE SOURCES OF HEAT/IGNITION. PROVIDE
ADEQUATE VENTILATION. SMALL: TAKE UP W/NONCOMBUSTIBLE ABSORBENT;
EARTH/SAND. PLACE INTO CONTAINERS. LARGE: CONTAIN IN EARTHEN DIKES
FOR LATER RECOVERY. CONTROL IGNITION SOURCES.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED & AWAY
FROM HEAT/FLAME.
Other Precautions:AVOID PROLONGED SKIN CONTACT W/USED MOTOR OILS. EMPTY
CONTAINERS MAY CONTAIN PRODUCT RESIDUE WHICH COULD INCLUDE
FLAMMABLE/EXPLOSIVE VAPORS.
* Physical/Chemical Properties *
Vapor Pres:(SEE SUPP)
Vapor Density:>1
Evaporation Rate & Reference:(BUTYL ACETATE=1): <1
Solubility in Water:<0.1%
Appearance and Odor:AMBER LIQUID W/SLIGHT PETROLEUM ODOR
Percent Volatiles by Volume:<0.1
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS, STRONG ACIDS, CAUSTICS
Stability Condition to Avoid:HEAT, FLAME & OTHER IGNITION SOURCES
Hazardous Decomposition Products:CO2, CO, TRACES OF OXIDES OF SULFUR,
ZINC & PHOSPHOROUS
* Disposal Considerations *
Waste Disposal Methods:USED OILS MAY BE PROCESSED BY AN APPROVED
RECYCLING FACILITY. DISPOSE OF IAW/LOCAL, STATE & FEDERAL
REGULATIONS. CONSULT FEDERAL/STATE & LOCAL AUTHORITIES BEFORE
REUSING/RECONDITIONING/RECLAIMING/RECY CLING/DISPOSING OF EMPTY
CONTAINERS/WASTE RESIDUE.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF EXPOSURE MAY OR DOES EXCEED OCCUPATIONAL
EXPOSURE LIMITS, USE A NIOSH-APPROVED RESPIRATOR TO PREVENT
ATMOSPHERE-SUPPLYING RESPIRATOR OR AN AIR-PURIFYING RESPIRATOR FOR
ORGANIC VAPORS.
Ventilation:USE EXPLOSION-PROOF VENTILATION AS REQUIRED TO CONTROL
VAPOR CONCENTRATIONS.
NATURAL RUBBER)
Other Protective Equipment:CLOTHING AS REQUIRED TO MINIMIZE CONTACT.
EYE WASH FOUNTAINS & SAFETY SHOWERS SHOULD BE AVAILABLE FOR
EMERGENCY USE.
Work Hygienic Practices:NONE PROVIDED BY MFR.
Supplemental Safety and Health
NONE PROVIDED BY MFR.
* Product Identification *
Product ID:ISOPROPYL ALCOHOL
CAGE:0A9L8
* Composition/Information on Ingredients *
Ingred Name:ISOPROPYL ALCOHOL
* Hazards Identification *
Health Hazards Acute and Chronic:EYE: MODERATELY IRRITATING TO THE
EYES. SKIN: MILDLY IRRITATING TO THE SKIN. INHALATION: MAY CAUSE
MILD IRRITATION TO THE NOSE, THROAT & RESPIRATORY TRACT & MAY
RESULT IN CENTRAL NERVOUS SYSTEM (CNS) DEPRESSION. INGESTION:
IRRITATING TO THE GASTROINTESTINAL TRACT, CAUSING ABDOMINAL PAIN &
VOMITING, SOMETIMES BLOODY. INGESTION MAY CAUSE CNS DEPRESSION, LOW
BLOOD PRESSURE, RAPID HEART BEAT & LIVER D AMAGE.
Explanation of Carcinogenicity:
Effects of Overexposure:IRRITATION AS NOTED IN HEALTH HAZARDS. EARLY TO
MODERATE CNS DEPRESSION MAY BE EVIDENCED BY GIDDINESS, HEADACHE,
DIZZINESS & NAUSEA; IN EXTREME CASES, UNCONSCIOUSNESS, RESPIRATORY
DEPRESSION & DEATH M AY OCCUR. LIVER DAMAGE MAY BE EVIDENCED BY
LOSS OF APPETITE, JAUNDICE (YELLOWISH SKIN COLOR) & SOMETIMES PAIN
IN THE UPPER ABDOMEN ON THE RIGHT SIDE
Medical Cond Aggravated by Exposure:PREEXISTING EYE, SKIN & RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT. IMPAIRED
FUNCTION FROM PREEXISTING DISORDERS MAY BE AGGRAVATED BY EXPOSURE
TO THIS PRODUCT
* First Aid Measures *
HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION. SKIN: FLUSH WITH
WATER. IF IRRITATION OCCURS, GET MEDICAL ATTENTION. INHALATION:
REMOVE VICTIM TO F RESH AIR & PROVIDE OXYGEN IF BREATHING IS
DIFFICULT. GET MEDICAL ATTENTION. INGESTION: DO NOT GIVE LIQUIDS IF
VICTIM IS UNCONSCIOUS OR VERY DROWSY. OTHERWIDE, GIVE NO MORE THAN
TABLESPOONS) SYRUP OF IPECAC. OR, GIVE 2 GLASSES OF WATER & INDUCE
VOMITING BY TOUCHING FINGER TO BACK OF VICTIM'S THROAT. KEEP HEAD
BELOW KNEES. GET MED HELP.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:2
Extinguishing Media:USE WATER FOG, "ALCOLOL" FOAM, DRY CHEMICAL OR CO2
Fire Fighting Procedures:WARNING. FLAMMABLE. CLEAR FIRE AREA OF
UNPROTECTED PERSONNEL. DO NOT ENTER CONFINED FIRE SPACE WITHOUT
RUBBER BOOTS), INCLUDING A POSI TIVE PRESSURE NIOSH APPROVED SELF
CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED CONTAINERS WITH
WATER.
Unusual Fire/Explosion Hazard:CONTAINERS EXPOSED TO INTENSE HEAT FROM
FIRES SHOULD BE COOLED WITH WATER TO PREVENT VAPOR PRESSURE BUILDUP
WHICH COULD RESULT IN CONTAINER RUPTURE. CONTAINER AREAS EXPOSED TO
DIRECT FLAME CONTACT SHO ULD BE COOLED WITH LG QUANTITIES OF WATER
AS NEEDED TO PREVENT WEAKENING OF CONTAINER STRUCTURE
* Accidental Release Measures *
Spill Release Procedures:WARNING. FLAMMABLE. ELIMINATE ALL IGNITION
SOURCES. HANDLING EQUIPMENT MUST BE GROUNDED TO PREVENT SPARKING.
LG SPILLS: EVACUATE THE HAZARD AREA OF UNPROTECTED PERSONNEL. WEAR
APPROPRIATE RESPIRATOR & PROTECTIVE CLOTHING. SHUT OFF SOURCE OF
LEAK ONLY IF SAFE TO DO SO. DIKE & CONTAIN. IF VAPOR CLOUD FORMS,
WATER FOG MAY BE USED TO SUPPRESS; CONTAIN RUN-OFF. REMOVE WITH
VACUUM TRUCKS OR PUMP TO STOR
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions: HMIS: STORE WITH
FLAMMABLES, AWAY FROM HIGH TEMPS AND OPEN FLAMES.
Other Precautions:KEEP LIQUID & VAPOR AWAY FROM HEAT, SPARKS & FLAME.
SURFACES THAT ARE SUFFICIENTLY HOT MAY IGNITE EVEN LIQUID PRODUCT
IN THE ABSENCE OF SPARKS OR FLAME. EXTINGUISH PILOT LIGHTS,
CIGARETTES & TURN OFF OTHER SOUCRES OF IGNITION PRIOR TO USE &
UNTIL ALL VAPORS ARE GONE.
* Physical/Chemical Properties *
HCC:F2
Decomp Temp:Decomp Text:
Vapor Density:2.1 (AIR=1
Viscosity:
Evaporation Rate & Reference:1.4 (BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS, MOBILE LIQUID. MILD ODOR
Percent Volatiles by Volume:NONE PROVIDE
Corrosion Rate:NONE PROVIDED BY MFR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:AVOID HEAT, SPARKS, FLAME & CONTACT WITH
STRONG OXIDIZING AGENTS. DO NOT STORE OR HANDLE IN ALUMINUM
Hazardous Decomposition Products:CARBON MONOXIDE & UNIDENTIFIED ORGANIC
COMPOUNDS MAY BE FORMED DURING COMBUSTION.
Conditions to Avoid Polymerization:WILL NOT OCCUR
* Disposal Considerations *
Waste Disposal Methods: HMIS: DISPOSE OF IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGS.
* MSDS Transport Information *
* Regulatory Information *
WASTE MATERIAL, IT WOULD BE IGNITABLE HAZARDOUS WASTE. HAZ WASTE #
DEPLETING SUBSTANCES. IN ACCORDANCE WITH SARA TITLE II, SECTION
MSDS.
Federal Regulatory Information:THIS PRODUCT IS LISTED ON THE EPA/TSCA
INVENTORY OF CHEMICAL SUBSTANCES.
State Regulatory Information:THIS CHEMICAL IS LISTED BY THE FOLLWING
STATES: CA, CT, FL, IL, LA, MA, ME, MN, NJ, PA AND RI.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:UNDER NORMAL USE CONDITIONS, RESPIRATOR IS NOT
USUALLY REQUIRED. USE NIOSH/MSHA APPROVED DISPOSABLE DUST/MIST MASK
IF THE RECOMMENDED EXPOSURE LIMIT IS EXCEEDED.
Ventilation:SUFFICIENT VENTILATION.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER. LONG
SLEEVE SHIRT IS RECOMMENDED. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
CONTAINS MINERAL OILS. UNDER CONDITIONS WHICH MAY GENERATE MISTS,
OBSERVE THE OSHA PEL OF 5 MG PER CUBIC METER.
* Product Identification *
CAGE:0F2M5
* Composition/Information on Ingredients *
Ingred Name:"NOT HAZARDOUS"
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-NOT EXPECTED TO CAUSE EYE/SKIN
IRRITATION.PROLONGED/REPEATED SKIN CONTACT MAY CAUSE
DERMATITIS.INHALATION:VAPORS/MISTS MAY CAUSE MUCOUS MEMBRANE & THE
UPPER RESPIRATORY TRACT IRRITATION.CHRONIC- NO DATA AVAILABLE TO
INDICATE CHRONIC HEALTH HAZARD.
Effects of Overexposure:SYMPTOMS OF SKIN DISORDER MAY INCLUDE REDNESS,
EDEMA, DRYING, DEFATTING AND CRACKING.
Medical Cond Aggravated by Exposure:NOT GIVEN.
* First Aid Measures *
First Aid:GET MEDICAL CARE.INHALATION: REMOVE TO FRESH AIR.EYE:FLUSH
SOAP AND WATER.INGESTION:DO NOT INDUCE VOMITING.IF CONSCIOUS, DRINK
2 GLA SSES OF WATER.GET MEDICAL ADVICE IMMEDIATELY.NOTE TO
PHYSICIAN:TREAT SYMPTOMATICALLY.
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:CARBON DIOXIDE, ALCOHOL FOAM, OR DRY CHEMICAL.
WATER CAN BE USED TO COOL AND PROTECT EXPOSED MATERIAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA.
Unusual Fire/Explosion Hazard:TOXIC FUMES, GASES OR VAPORS
* Accidental Release Measures *
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. VENTILATE
AREA.PREVENT ENTRY INTO SEWERS & WATERWAYS. PICK UP FREE LIQUID FOR
RECYCLE/DISPOSAL. RESIDUAL LIQUID CAN BE ABSORBED ON INERT
MATERIAL.
*Handling and Storage *
Handling and Storage Precautions:STORAGE-STORE IN A COOL,DRY,VENTILATED
AREA AWAY FROM HEAT & FLAMES.
Other Precautions:MINIMIZE SKIN CONTACT.WASH WITH SOAP & WATER BEFORE
EATING OR DRINKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.KEEP
CONTAINERS CLOSED WHEN NOT IN USE.EMPTY CONTAINER CONTAINS RESIDUE
WHICH MAY EXH IBIT HAZARDS OF PRODUCT.
* Physical/Chemical Properties *
HCC:V6
Solubility in Water:INSOLUBLE
Appearance and Odor:BROWN LIQUID - MILD ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:SMOKE, CARBON MONOXIDE, ALDEHYDES,
OXIDES OF SULFUR AND OTHER PRODUCTS OF INCOMPLETE COMBUSTION.
* Disposal Considerations *
Waste Disposal Methods:MATERIAL, IF DISCARDED, NOT EXPECTED TO BE A
CHARACTERISTIC HAZARDOUS WASTE UNDER RCRA. DISPOSE OF IN AN
APPROPRIATE DISPOSAL FACILITY IN COMPLIANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:NO SPECIAL REQUIREMENTS.
Supplemental Safety and Health
MANUALLY BURST INNER BAG AND MIX CHEMICALS TO PRODUCE COLD TEMPERATURE.
* Product Identification *
Preparer's Name:DENNIS J. BREUNIG
CAGE:0FBL1
CAGE:0FBL1
* Composition/Information on Ingredients *
Ingred Name:AMMONIUM NITRATE
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Health Hazards Acute and Chronic:TARGET ORGANS: EYE, SKIN,
GASTROINTESTINAL TRACT. ACUTE- EYES: POSSIBLE IRRITATION. SKIN:
POSSIBLE RASH FROM PROLONGED EXPOSURE. INHALATION: NOT LIKELY TO
OCCUR IN NORMAL USE. INGESTION: MAY CAUSE INT ESTINAL BLEEDING,
RAPID BREATHING & HEART RATE, NAUSEA, VOMITING, STOMACH PAIN,
WEAKNESS, COMA, CONVULSION AND /OR DEATH. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, RASH, STOMACH PAIN, NAUSEA,
VOMITING, INTESTINAL BLEEDING, RAPID BREATHING AND HEART RATE,
WEAKNESS, COMA, CONVULSION AND/OR DEATH.
* First Aid Measures *
First Aid:SKIN/EYES: FLUSH THOROUGHLY WITH RUNNING WATER. INGESTION:
INDUCE VOMITING AND GET MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point:NON-FLAMMABLE
Autoignition Temp:Autoignition Temp Text:NP
Extinguishing Media:WATER SPRAY ONLY.
Fire Fighting Procedures:WATER SPRAY ONLY.
Unusual Fire/Explosion Hazard:DO NOT LET AMMONIUM NITRATE COME IN
CONTACT WITH OIL. POSSIBLE EXPLOSION IF MIXED WITH OIL IN RIGHT
QAUNTITIES.
* Accidental Release Measures *
Spill Release Procedures:WIPE UP WITH WATER AND ABSORBENT MATERIALS
(RAGS).
*Handling and Storage *
Handling and Storage Precautions:STOREAND HANDLEIN A COOL DRY
ENVIRONMENT.
Other Precautions:N?A
* Physical/Chemical Properties *
HCC:D1
NRC/State Lic Num:NOT RELEVANT
Viscosity:NP
Solubility in Water:COMPLETE
Appearance and Odor:MILKY WHITE LIQUID WHEN ACTIVATED.
Percent Volatiles by Volume:NONE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OIL
Stability Condition to Avoid:PROXIMITY AND CONTACT WITH OIL.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. DISPOSE OF IN NORMAL WASTE RECEPTICLE.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONSS FOUND IN
Ventilation:ENGINEERING CONTROLS: USE PROCESS ENCLOSURE, LOCAL EXHAUST
VENTILATION, OR OTHER ENGINEERING CONTROLS TO CONTROL AIRBORNE
LEVELS BELOW REC EXPOSURE LIMITS.
EXPOSURE.
Other Protective Equipment:WEAR APPROP PROTECTIVE CLOTHING TO PREVENT
SKIN EXPOSURE. EYE WASH AND DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA .
Supplemental Safety and Health
* Product Identification *
CAGE:0RPY6
* Composition/Information on Ingredients *
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CAUSES SEVERE RESPIRATORY
TRACT, DIGESTIVE TRACT, EYE, AND SKIN IRRITATION. MAY CAUSE KIDNEY
DAMAGE, CNS DEPRESSION, AND REPRODUCTIVE EFFECTS. TARGET ORGANS:
KIDNEYS, CNS, AND REPRODUCTIVE SYST EM. PRODUCES IRRIT, BURNING
SENSATION, REDNESS, TEARING, INFLAMM & POSS CORNEAL INJURY.SKIN:
PROLONGED/ REPEATED CONTACT MAY CAUSE DEFATTING OF SKIN &
DERMATITIS ESP IF SKIN IS ABRADED. INGESTION: MA Y CAUSE GI IRRIT
W/NAUSEA, VOMIT, DIARR. MAY CAUSE CNS EFFECTS CHARACT BY
EXCITEMENT, HDCH, DIZZ, DROW, & NAUSEA. ADVANCED STAGES MAY CAUSE
COLLAPS, (SIGNS OF OVEREXP)
CALOFORNIA: NOT LISTED, NIOSH: NOT LISTED, NTP: NOT LISTED, OSHA:
CLASSIFIABLE AS A HUMAN CARCINOGEN, CALIF ORNIA: NOT LISTED, NIOSH:
NOT LISTED, NTP: NOT LISTED, OSHA:NOT LISTED, IARC: NOT LISTED.
Effects of Overexposure:HEALTH HAZARDS (CONT): UNCONSCIOUSNESS, COMA
AND POSSIBLY DEATH DUE TO RESPIRATORY FAILURE. INHALATION: HIGH
CONCENTRATIONS MAY CAUSE CNS EFFECTS CHARACTERIZED BY HEADACHE,
DIZZINESS, UNCINSCIOUSNESSAND COMA. INHALATION OF VAPOR MAY CAUSE
RESPIRATORY TRACT INFECTION. MAY CAUSE NARCOTIC EFFECTS. CHRONIC:
PROLONGED OR REPEATED SKIN CONTACT MAY CAUSE DEFATTING AND
DERMATITIS.
* First Aid Measures *
OCCASNLY LIFTING UPPER/LOWER LIDS. GET MED AID IMMED. SKIN: IMMED
CLTH/S HOES. GET MED AID IF IRRIT DEVELOPS OR PERSISTS. INGEST: IF
VICTIM CONCIOUS & ALERT, GIVE 2-4 CUPFULS MILK/H2*O. NEVER GIVE
ANYTHING BY MOUTH TO UNCON PERSON. INDUCE VOMIT BY GIVING 1
TEASPOON SYRUP O F IPECAC. INHAL:GET MED AID IMMED. REMOVE FROM
EXPOS TO FRESH AIR IMMED. IF NOT BREATHING, GIVE ARTF RESP. IF
BREATH DFCLT, GIVE OXYG. NOTES TO MD: TREAT SYMPTOMATICALLY &
SUPPORTIVELY.
* Fire Fighting Measures *
Lower Limits:3.5
Extinguishing Media:FOR SMALL FIRES, USE WATER SPRAY, DRY CHEM, CO*2 OR
CHEM FOAM. USE WATER SPRAY TO COOL FIRE-XPOSED CONTAINERS. H2*O MAY
BE INEFFECTIVE.
Fire Fighting Procedures:GEN INFO: AS IN ANY FIRE, WEAR SCBA IN
PRESSURE-DEMAND, MSHA/NIOSH(APPRV OR EQUIV)& FULL PROT GEAR. VAPORS
CAN TRAVEL TO A SOURCE OF IGNIT & FLASHBACK. CONTRS MAY EXPLO IN
HEAT OF FIRE. MAY FORM EXPLO PEROXIDES. VAPORS MAY BE HEAVIER THAN
AIR & SPREAD QUICKLY ALONG THE GROUND & COLLECT IN LOW OR CONFINED
AREAS.
Unusual Fire/Explosion Hazard:DANGER! EXTREMELY FLAMMABLE LIQUID. MAY
FORM EXPLOSIVE PEROXIDES.
* Accidental Release Measures *
Spill Release Procedures:ABSORB SPILL W/INERT MATL (EG,DRY SAND/EARTH)
THEN PLACE INTO CHEM WASTE CONTR. CLEANUP SPILLS IMMED, OBSERVING
PRECAUTNS IN PROT EQUIP SECTION. SCOOP UP W/NONSPARKING TOOL, THEN
PLACE INTO SUITABLE C ONTR FOR DISP. REMOVE ALL SOURCES OF
IGNITION.
*Handling and Storage *
Handling and Storage Precautions:HANDLING: WASH THOROUGHLY AFTER HANDL
& BEFORE EATING. USE IN WELL-VENT AREA.USE SPARK-PROOF TOOLS &
EXPLO PROOF EQUIP. EMPTY CONTAINERS RETAIN PRODUCT
RESIDUE(LIQUID/VAPOR) & CAN BE DANGEROUS. DO NOT GET ON SKIN/IN
EYES OR INGEST/INHAL. DO NOT (OTHER PREC)
Other Precautions:HANDLIN & STORAGE (CONT):
PRESSURIZE,CUT,WELD,BRAZE,SOLDER,DRILL,GRIND OR EXPOSE EMPTY
CONTAINERS TO HEAT, SPARKS OR OPEN FLAMES. STORAGE: KEEP AWAY FROM
HEAT,SPARKS&FLAME,SOURCES OF IGNIT. STORE IN C OOL,DRY PLACE IN
TIGHTLY CLOSED CONTAINER. STORAGE CODE: RED
* Physical/Chemical Properties *
Vapor Density:2.0-2.1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID WITH PUNGENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG REDUCING AGENTS, ISOPROPANOL IS SUSCEPTIBLE TO AUTOXIDATION &
THEREFORE SHOULD BE CLASSIFIED AS PEROXIDIZ ABLE. STABILITY COND
TO AVOID (CONT): THIS MATL MAY BE SENSITIVE TO PEROXIDE FORMATION.
Stability Condition to Avoid:HIGH TEMPS, MECH SHOCK, IMCOMPAT MATLS,
IGNIT SOURCES, EXCESS HEAT. CHEM STABILITY: STABLE AT ROOM TEMP IN
CLOSED CONTRS UNDER NORMAL STOR & HANDLING CONDITIONS. (MAT'L TO
AVOID)
Hazardous Decomposition Products:OXIDES OF CARBON.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Toxicological Information*
REPRODUCTIVE: N/P.MUTAGENICITY : N/P. NEUROTOXICITY: N/P.
* Ecological Information *
Ecological:NO INFORMATION AVAILABLE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW FED, STATE & LOCAL REGS. RCRA
D-MAX CONC OF CONTAM-NONE OF COMPONENTS ARE ON THIS LIST. RCRA D
SERIES-CHRONIC TOXICITY REF LEVELS-NONE OF COMP ARE ON THIS LIST.
* MSDS Transport Information *
Transport Information:SHIPPING NAME: (US DOT) FLAMMABLE LIQUIDS,
GROUP II. (IATA), (IMO), (RID/ADR), (CANADIAN TDG): NO INFORMATION
AVAILABLE.
* Regulatory Information *
SARA Title III Information:THRESHOLD PLANNING QUANTITIES (TPQ)-NONE OF
POLLUTANTS(HAPS)/CLEAN AIR ACT-CLASS 1 OZON E DEPLETORS: NONE OF
COMPONENTS ARE ON THIS LIST.
LISTED ON TSCA INVENTORY. HEALTH & SAFETY REPORTING
EXPORT NOTIF REQ'D-SECTION 4. TSCA SIGNIFICANT NEW USE RULE (SNU
R):NONE OF COMPONENTS ON THIS LIST. CERCLA REPORTABLE QUANTITIES
(TPQ): NONE OF THE COMPONENTS ARE O N THIS LIST.
State Regulatory Information:ISOPROPYL ALCOHOL & ACETONE CAN BE FOUND
ON THESE STATE RIGHT-TO-KNOW LISTS: CA, NJ, FL, PA, MN, MS.
AVAILABLE.
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR APPROPRIATE, PROPERLY FITTED RESPIRATOR
(NIOSH/MSHA APPRVD) DURING & AFTER APPLICATION UNLESS AIR
MONITORING VAPOR/MIST LEVELS ARE BELOW APPLICABLE LIMITS. FOLLOW
RESPIRATOR MANUFACTURER'S DIRECT IONS FOR RESPIRATOR USE.
Ventilation:REQUIRED FOR SPRAYING OR IN A CONFINED AREA; VENTILATION
EQUIPMENT SHOULD BE EXPLOSION PROOF.
Other Protective Equipment:NEOPRENE OR PLASTIC APRON & PROTECTIVE
CLOTHING COVERING EXPOSED SKIN AREAS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
& RESP SENSITIZER. CNTNS INGREDS WHICH MAY CAUSE LIVER, KIDNEY DMG,
CORNEAL INJURY/EYE DMG, PULM EDEMA.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: HARMFUL IF INHALED. MAY AFFECT
BRAIN, NERVOUS/RESP SYS, CAUSING DIZZ, HDCH, NAUS/RESP IRRIT.
OVEREXP MAY CAUSE NOSE & THROAT IRRIT, EYE IRRIT, EYE BURNS, SKIN
IRRIT, ALLERGIC SKIN RXN, RESP TRA CT IRRIT, DERM, CORNEAL
INJURY/EYE DMG.CHRONIC: POSS SENSIT. PRLNG EXPOS TO RESPIRABLE
CRYSTALLINE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC
REPORT ON (SUPDAT)
Effects of Overexposure:HLTH HAZ: QUARTZ MAY CAUSE DELAYED LUNG INJURY
(SILICOSIS). CONTAINS INGREDS WHICH MAY CAUSE CANCER. RISK DEPENDS
ON DURATION & LEVEL OF EXPOS. NOTICE:RPTS HAVE ASSOC RPTD & PRLNG
OCCUP OVEREXP TO SOL V W/PERM BRAIN & NERVOUS SYS DMG. INTENTIONAL
MISUSE BY DELIB CONC & INHAL CONTENTS MAY BE HARMFUL/FATAL. POSS
(SUPDAT)
Medical Cond Aggravated by Exposure:ANY RESPIRATORY OR SKIN CONDITION.
* First Aid Measures *
GET MED ATTN. SKIN: WASH THOROUGHLY W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING & SHOES. WASH CLOTHING BEFORE REUSE. DESTROY
CONTAMINATED SHOES. INHAL: REMOVE TO FRESH AIR. IF NOT BREATHING,
GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, GIVE
OXYGEN. GET MED ATTN IMMED. INGEST: IF SWALLOWED, GET MED ATTN
IMMED.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM AND/OR WATER
FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . CONTAINERS EXPOSED TO FIRE SHOULD BE KEPT
COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA. AVOID BREATHING VAPORS. USE
NIOSH/MSHA APPROVED SELF-CONTAINED BREATHING APPARATUS OR AIRMASK
FOR LARGE SPILLS IN A CONFINED AREA. AVOID ALL PERSONAL CONTACT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPK & OPEN
Other Precautions:EMPTY CONTAINERS MAY CONTAIN PRODUCT RESIDUE,
INCLUDING FLAMMABLE OR EXPLOSIVE VAPORS. DO NOT CUT, PUNCTURE OR
WELD ON OR NEAR CONTAINER. ALL LABEL WARNINGS MUST BE OBSERVED
UNTIL CONTAINER HAS BEEN C LEANED OR RECONDITIONED.
* Physical/Chemical Properties *
Vapor Density:5.9
Evaporation Rate & Reference:0.5 (BUTYL ACETATE=1)
Solubility in Water:NO
Appearance and Odor:NORMAL FOR A COATINGS PRODUCT.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:SILICON DIOXIDE, CARBON MONOXIDE,
CARBON DIOXIDE, METAL OXIDES, SULFUR OXIDES.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN CHEMICAL DISPOSAL AREA OR IN A MANNER
THAT COMPLIES WITH LOCAL, STATE AND FEDERAL REGULATIONS. DO NOT
INCINERATE CLOSED CONTAINERS.
| 1 | eyes_protection_mandatory |
Control Measures
*
Proprietary Ind: Y
*
Contractor Summary
*
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: ACUTE:OVEREXP MAY CAUSE LUNG DMG. MAY CAUSE ALLERGIC SKIN
& RESP RXN; EFTS MAY BE PERM. MAY AFFECT BRAIN CAUSING DIZZ, HDCH OR
NAUS. CAUSES EYE, SKIN, NOSE & THROAT IRRIT. RPTS HAVE ASSOC RPTD &
PRLNG D OCCUP EXPOS TO SOLVS W/PERM BRAIN & NERV SYS DMG. INTENTIONAL
MISUSE BY DELIB CONC & INHAL CONTENTS (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: TOLUENE DIISOCYANATE:IARC MONO, SUPP, VOL 7, PG
Signs And Symptions Of Overexposure: HLTH HAZ:MAY BE HARMFUL/FATAL. WARNING:MAY
CNTN LOW RESIDUAL AMTS OF CHEM(S) KNOWN TO ST OF CA TO CAUSE CANCER, BIRTH
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL:REMOVE TO FRESH AIR. IF BRTHG IS DFCLT, GIVE OXYG. IF NOT
BRTHG GIVE ARTF RESP & GET MED ATTN. EYE:FLUSH W/PLENTY OF WATER FOR @
BEFORE REUSE. INGEST:GET MED ATTN IMMED. NOTE:IF ANY CNDTNS PERSIST/OCCUR
LATER, CONSULT PHYS & HAVE MSDS AND/OR LABEL INFORMATION AVAILABLE.
*
Handling and Disposal
*
Spill Release Procedures: ELIMINATE SOURCE IF SAFE TO DO SO. ABSORB WITH INERT
MATERIAL OR ALLOW TO HARDEN AND SCRAPE UP. TAKE PROPER PRECAUTIONS
THROUGHOUT.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: INCINERATE OR LANDFILL IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL REGULATIONS.
Handling And Storage Precautions: PROTECT AGAINST PHYSICAL DMG. KEEP CNTNR CLSD
WHEN NOT IN USE. STORE AWAY FROM HEAT, SPARKS & FLAME. AVOID CONT W/EYES,
SKIN & CLOTHING.
Other Precautions: USE WITH ADEQUATE VENT. DO NOT BREATHE VAPS. DO NOT TAKE
INTERNALLY. FOR INDUST/COMMERCIAL USE ONLY. KEEP OUT OF REACH OF CHILDREN.
*
Fire and Explosion Hazard Information
*
Flash Point Method: SCC
Extinguishing Media: WATERSPRAY, WATERFOG, DRY CHEMICAL, CO*2, FOAM. (TREAT AS
CLASS B FIRE).
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: SOLV VAPS ARE HVR/AIR & MAY FLOW ALONG SURF
TO SOURCE OF IGNIT & FLASH BACK. TOX GASES MAY OCCUR AS DECOMP PRODS. RXN
W/WATER PRDCES CO*2 WHICH COULD (SUPDAT)
*
*
Respiratory Protection: USE W/ADEQ VENT. NIOSH/MSHA APPRVD RESPS W/ORG VAP
CARTRIDGES OR NIOSH/MSHA APPRVD SCBA MAY BE USED IN CONFINED AREAS. FOLLOW
RESP SUPPLIER'S REC & DIRECTIONS FOR USE. INDIVIDUALS W/LUNG OR BRTHG
PROB LEMS/PRIOR RXN TO ISOCYANATES (SUPDAT)
Ventilation: LOCAL EXHAUST OR GENERAL MECHANICAL SUFFICIENT TO PVNT
ACCUMULATION OF FUMES AND VAPORS.
Other Protective Equipment: ANSI APPRVD EMERGENCY EYE WASH & DELUGE SHOWER (FP
N).
Work Hygienic Practices: WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health: EXPLO HAZ:CAUSE PRESS TO BUILD UP IN CNTNR.
PRESS MAY ALSO BUILD IN CLSD CNTNRS IF HEATED. RESP PROT:MUST NOT BE EXPOSED
TO VAPORS OR SPRAY MIST.
*
Physical/Chemical Properties
*
Vapor Density: HVR/AIR
Evaporation Rate & Reference: SLOWER THAN ETHER
Solubility in Water: NOT KNOWN
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: STORE AWAY FROM HEAT, SPRAKS & FLAME.
Materials To Avoid: WATER, ALCOHOLS, STRONG OXIDIZING AGENTS, STRONG ACIDS,
STRONG BASES.
Hazardous Decomposition Products: PRODS OF COMBUST MAY INCL:NITROGEN OXIDES,
CARBON MONOXIDE, CARBON DIOXIDE, HYDROGEN CYANIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Assigned IND: Y
Company Name: MEMECO INTERNATIONAL INC
Label Required IND: Y
Status Code: C
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Moderate
Reactivity Hazard: Slight
Hazard And Precautions: COMBUSTIBLE. AVOID WATER. ACUTE:MAY CAUSE LUNG DAMAGE,
ALLERGIC SKIN AND RESPIRATORY REACTION. MAY AFFECT BRAIN, CAUSING DIZZINESS,
HEADACHE/NAUSEA. CAUSES EYE, SKIN, NOSE AND THROAT IRRITATION. CHRON
IC:CANCER HAZARD. CONTAINS TOLUENE DIISOCYANTE, WHICH IS LISTED AS A LIVER
CARCINOGEN (FP N). SKIN AND RESPIRATORY TRACT SENSITIZATION (FP N).
PROLONGED/REPEATED OVEREXPOSURE MAY LEAD TO PERMANENT BRA IN AND NERVOUS
SYSTEM DAMAGE.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONSS FOUND IN
Ventilation:ENGINEERING CONTROLS: USE PROCESS ENCLOSURE, LOCAL EXHAUST
VENTILATION, OR OTHER ENGINEERING CONTROLS TO CONTROL AIRBORNE
LEVELS BELOW REC EXPOSURE LIMITS.
EXPOSURE.
Other Protective Equipment:WEAR APPROP PROTECTIVE CLOTHING TO PREVENT
SKIN EXPOSURE. EYE WASH AND DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA .
Supplemental Safety and Health
* Product Identification *
CAGE:0RPY6
* Composition/Information on Ingredients *
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CAUSES SEVERE RESPIRATORY
TRACT, DIGESTIVE TRACT, EYE, AND SKIN IRRITATION. MAY CAUSE KIDNEY
DAMAGE, CNS DEPRESSION, AND REPRODUCTIVE EFFECTS. TARGET ORGANS:
KIDNEYS, CNS, AND REPRODUCTIVE SYST EM. PRODUCES IRRIT, BURNING
SENSATION, REDNESS, TEARING, INFLAMM & POSS CORNEAL INJURY.SKIN:
PROLONGED/ REPEATED CONTACT MAY CAUSE DEFATTING OF SKIN &
DERMATITIS ESP IF SKIN IS ABRADED. INGESTION: MA Y CAUSE GI IRRIT
W/NAUSEA, VOMIT, DIARR. MAY CAUSE CNS EFFECTS CHARACT BY
EXCITEMENT, HDCH, DIZZ, DROW, & NAUSEA. ADVANCED STAGES MAY CAUSE
COLLAPS, (SIGNS OF OVEREXP)
CALOFORNIA: NOT LISTED, NIOSH: NOT LISTED, NTP: NOT LISTED, OSHA:
CLASSIFIABLE AS A HUMAN CARCINOGEN, CALIF ORNIA: NOT LISTED, NIOSH:
NOT LISTED, NTP: NOT LISTED, OSHA:NOT LISTED, IARC: NOT LISTED.
Effects of Overexposure:HEALTH HAZARDS (CONT): UNCONSCIOUSNESS, COMA
AND POSSIBLY DEATH DUE TO RESPIRATORY FAILURE. INHALATION: HIGH
CONCENTRATIONS MAY CAUSE CNS EFFECTS CHARACTERIZED BY HEADACHE,
DIZZINESS, UNCINSCIOUSNESSAND COMA. INHALATION OF VAPOR MAY CAUSE
RESPIRATORY TRACT INFECTION. MAY CAUSE NARCOTIC EFFECTS. CHRONIC:
PROLONGED OR REPEATED SKIN CONTACT MAY CAUSE DEFATTING AND
DERMATITIS.
* First Aid Measures *
OCCASNLY LIFTING UPPER/LOWER LIDS. GET MED AID IMMED. SKIN: IMMED
CLTH/S HOES. GET MED AID IF IRRIT DEVELOPS OR PERSISTS. INGEST: IF
VICTIM CONCIOUS & ALERT, GIVE 2-4 CUPFULS MILK/H2*O. NEVER GIVE
ANYTHING BY MOUTH TO UNCON PERSON. INDUCE VOMIT BY GIVING 1
TEASPOON SYRUP O F IPECAC. INHAL:GET MED AID IMMED. REMOVE FROM
EXPOS TO FRESH AIR IMMED. IF NOT BREATHING, GIVE ARTF RESP. IF
BREATH DFCLT, GIVE OXYG. NOTES TO MD: TREAT SYMPTOMATICALLY &
SUPPORTIVELY.
* Fire Fighting Measures *
Lower Limits:3.5
Extinguishing Media:FOR SMALL FIRES, USE WATER SPRAY, DRY CHEM, CO*2 OR
CHEM FOAM. USE WATER SPRAY TO COOL FIRE-XPOSED CONTAINERS. H2*O MAY
BE INEFFECTIVE.
Fire Fighting Procedures:GEN INFO: AS IN ANY FIRE, WEAR SCBA IN
PRESSURE-DEMAND, MSHA/NIOSH(APPRV OR EQUIV)& FULL PROT GEAR. VAPORS
CAN TRAVEL TO A SOURCE OF IGNIT & FLASHBACK. CONTRS MAY EXPLO IN
HEAT OF FIRE. MAY FORM EXPLO PEROXIDES. VAPORS MAY BE HEAVIER THAN
AIR & SPREAD QUICKLY ALONG THE GROUND & COLLECT IN LOW OR CONFINED
AREAS.
Unusual Fire/Explosion Hazard:DANGER! EXTREMELY FLAMMABLE LIQUID. MAY
FORM EXPLOSIVE PEROXIDES.
* Accidental Release Measures *
Spill Release Procedures:ABSORB SPILL W/INERT MATL (EG,DRY SAND/EARTH)
THEN PLACE INTO CHEM WASTE CONTR. CLEANUP SPILLS IMMED, OBSERVING
PRECAUTNS IN PROT EQUIP SECTION. SCOOP UP W/NONSPARKING TOOL, THEN
PLACE INTO SUITABLE C ONTR FOR DISP. REMOVE ALL SOURCES OF
IGNITION.
*Handling and Storage *
Handling and Storage Precautions:HANDLING: WASH THOROUGHLY AFTER HANDL
& BEFORE EATING. USE IN WELL-VENT AREA.USE SPARK-PROOF TOOLS &
EXPLO PROOF EQUIP. EMPTY CONTAINERS RETAIN PRODUCT
RESIDUE(LIQUID/VAPOR) & CAN BE DANGEROUS. DO NOT GET ON SKIN/IN
EYES OR INGEST/INHAL. DO NOT (OTHER PREC)
Other Precautions:HANDLIN & STORAGE (CONT):
PRESSURIZE,CUT,WELD,BRAZE,SOLDER,DRILL,GRIND OR EXPOSE EMPTY
CONTAINERS TO HEAT, SPARKS OR OPEN FLAMES. STORAGE: KEEP AWAY FROM
HEAT,SPARKS&FLAME,SOURCES OF IGNIT. STORE IN C OOL,DRY PLACE IN
TIGHTLY CLOSED CONTAINER. STORAGE CODE: RED
* Physical/Chemical Properties *
Vapor Density:2.0-2.1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID WITH PUNGENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG REDUCING AGENTS, ISOPROPANOL IS SUSCEPTIBLE TO AUTOXIDATION &
THEREFORE SHOULD BE CLASSIFIED AS PEROXIDIZ ABLE. STABILITY COND
TO AVOID (CONT): THIS MATL MAY BE SENSITIVE TO PEROXIDE FORMATION.
Stability Condition to Avoid:HIGH TEMPS, MECH SHOCK, IMCOMPAT MATLS,
IGNIT SOURCES, EXCESS HEAT. CHEM STABILITY: STABLE AT ROOM TEMP IN
CLOSED CONTRS UNDER NORMAL STOR & HANDLING CONDITIONS. (MAT'L TO
AVOID)
Hazardous Decomposition Products:OXIDES OF CARBON.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Toxicological Information*
REPRODUCTIVE: N/P.MUTAGENICITY : N/P. NEUROTOXICITY: N/P.
* Ecological Information *
Ecological:NO INFORMATION AVAILABLE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW FED, STATE & LOCAL REGS. RCRA
D-MAX CONC OF CONTAM-NONE OF COMPONENTS ARE ON THIS LIST. RCRA D
SERIES-CHRONIC TOXICITY REF LEVELS-NONE OF COMP ARE ON THIS LIST.
* MSDS Transport Information *
Transport Information:SHIPPING NAME: (US DOT) FLAMMABLE LIQUIDS,
GROUP II. (IATA), (IMO), (RID/ADR), (CANADIAN TDG): NO INFORMATION
AVAILABLE.
* Regulatory Information *
SARA Title III Information:THRESHOLD PLANNING QUANTITIES (TPQ)-NONE OF
POLLUTANTS(HAPS)/CLEAN AIR ACT-CLASS 1 OZON E DEPLETORS: NONE OF
COMPONENTS ARE ON THIS LIST.
LISTED ON TSCA INVENTORY. HEALTH & SAFETY REPORTING
EXPORT NOTIF REQ'D-SECTION 4. TSCA SIGNIFICANT NEW USE RULE (SNU
R):NONE OF COMPONENTS ON THIS LIST. CERCLA REPORTABLE QUANTITIES
(TPQ): NONE OF THE COMPONENTS ARE O N THIS LIST.
State Regulatory Information:ISOPROPYL ALCOHOL & ACETONE CAN BE FOUND
ON THESE STATE RIGHT-TO-KNOW LISTS: CA, NJ, FL, PA, MN, MS.
AVAILABLE.
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:POSITIVE PRESSURE SELF-CONTAINED BREATHING
Ventilation:LOCAL EXHAUST RECOMMENDED, MECHANICAL (GENERAL)
RECOMMENDED.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING, EYE WASH,
SAFETY SHOWER.
Work Hygienic Practices:WORK SAFELY. RESPECT THE MATERIAL. WASH AFTER
HANDLING.
Supplemental Safety and Health
NONE
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:CHLOROFORM(SARA III)
Other REC Limits: SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:MAY BURN SKIN AND EYES. POTENT
ANESTHETIC AT HIGH CONCENTRATION. DEATH HAS RESULTED FROM LIVER AND
CARDIAC FAILURE.
Explanation of Carcinogenicity:SEE APPROPRIATE REPORT FOR DETAILS.
Effects of Overexposure:LASSITUDE, DIGESTIVE DISTURBANCE, MENTAL
DULLNESS, COMA.
Medical Cond Aggravated by Exposure:SKIN, LIVER, KIDNEY, HEART,
RESPIRATORY.
* First Aid Measures *
First Aid:SKIN AND EYES:IMMEDIATE WATER FLUSH. INHALATION:FRESH AIR.
INGESTION:INDUCE VOMITING ONLY IF CONSCIOUS. CALL A PHYSICIAN!
* Fire Fighting Measures *
Flash Point:
Lower Limits:NOT REPORTED
Upper Limits:NOT REPORTED
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, ALCOHOL FOAM, WATER
SPRAY.
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT AND POSITIVE
PRESSURE SELF-CONTAINED BREATHING APPARATUS. STAY UPWIND, OUT OF
LOW AREAS.
Unusual Fire/Explosion Hazard:HEAT OF FIRE AND RUNOFF FROM FIRE CONTROL
WATER MAY PRODUCE POISONOUS GASES.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE IGNITION SOURCES. USE WATER SPRAY TO
REDUCE VAPORS. WEAR FULL-PROTECTIVE EQUIPMENT AND POSITIVE PRESSURE
SELF-CONTAINED BREATHING APPARATUS. TAKE UP WITH AN NON-COMBUSTIBLE
ABSORBENT AND CON TAINERIZE FOR LATER DISPOSAL.
Neutralizing Agent:NO INFORMATION GIVEN ON MSDS BY MFR.
*Handling and Storage *
Handling and Storage Precautions:AVOID VAPORS. AVOID SKIN, EYE AND
CLOTHING CONTACT. KEEP CONTAINER CLOSED. STORE IN A COOL AREA
Other Precautions:OBSERVE ALL PRECAUTIONS WHEN HANDLING EMPTY
CONTAINERS AND POSSIBLE RESIDUE THEREIN.
* Physical/Chemical Properties *
HCC:T3
NRC/State Lic Num:
Appearance and Odor:COLORLESS LIQUID, ETHER LIKE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACETONE, SODIUM OXKDI, CAUSTICS, ACTIVE METALS, ALUMINUM, SODIUM,
POTASSIUM.
Stability Condition to Avoid:HEAT, HOT SURFACES, FLAMES, SPARKS, AIR,
DIRECT SUNLIGHT, EXCESS WATER, WELDING EQUIPMENT.
Hazardous Decomposition Products:PHOSGENE, HYDROGEN CHLORIDE,
CHLORIDES, OXIDES OF CARBON.
Conditions to Avoid Polymerization:MFS STATES:"WILL NOT OCCUR" BUT ADDS
"HEAT, HOT SURFACES"!?
* Disposal Considerations *
Waste Disposal Methods:TO BE PERFORMED IN COMPLIANCE WITH ALL LOCAL,
STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED RESPIRATOR WHEN OPERATING ABOVE
THE SUGGESTED TLV LIMITS.
Ventilation:LOCAL EXHAUST
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ISOPARAFFINIC HYDROCARBONS (NAPHTHA PETROLEUM),
HYDROTREATED HEAVY, NON AROMATIC HEAVY NAPHTHA) ISOPAR G
Ingred Name:CARBON DIOXIDE
Fraction by Wt: 3.5%
Ingred Name:PROPRIETARY MIXTURE OF ORGANIC CHEMICALS
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: EXCESSIVE REPEATED CONTACT
OF CONCENTRATED MATERIAL MAY CAUSE IRRITATION. EYES: MAY CAUSE
IRRITATION. SKIN: MAY CAUSE IRRITATION &/DERMATITIS. INGESTION:
HARMFUL IF ASPIRATED INTO LUNGS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH THOROUGHLY
CONTACT W/GENEROUS AMOUNTS OF WATER. INGESTION: DON'T INDUCE
VOMITING. GIVE PLENT Y OF WATER. OBTAIN MEDICAL ATTENTION INALL
CASES.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits: 0.8
Upper Limits: 8.5
Extinguishing Media:DRY CHEMICAL, WATER SPRAY, FOAM
Fire Fighting Procedures:USE WATER SPRAY TO COOL FIRED EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:EXPOSURE TO HEAT MAY CAUSE BURSTING.
* Accidental Release Measures *
Spill Release Procedures:PRODUCT CONTAINED IN AEROSOL CANS.
*Handling and Storage *
SPARKS, OPEN FLAME, HEATED SURFACES/ANY OTHER SOURCE OF IGNITION.
Other Precautions:THIS CONTAINER MAY BE HAZARDOUS WHEN EMPTIED. EMPTIED
CONTAINERS MAY RETAIN PRODUCT RESIDUES (VAPORS/LIQUID). DON'T
BREATHE VAPOR/SPRAY MIST.
* Physical/Chemical Properties *
Vapor Pres:0.7
Vapor Density:5.7
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR WATER W/WHITE LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
HEATED SURFACES & OTHER SOURCE OF IGNITION.
Hazardous Decomposition Products:OXIDES OF CARBON
* Disposal Considerations *
IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:SUITABLE PROTECTIVE CLOTHING, SAFETY SHOWER
& EYE BATH
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:DIACETONE ALCOHOL
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE HARMFUL BY INHALATION,
INGESTION/SKIN ABSORPTION. MAY CAUSE EYE, SKIN, MUCOUS MEMBRANE &
UPPER RESPIRATORY TRACT IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:MAY BE HARMFUL BY INHALATION, INGESTION/SKIN
ABSORPTION. MAY CAUSE EYE, SKIN, MUCOUS MEMBRANE & UPPER
RESPIRATORY TRACT IRRITATION.
* First Aid Measures *
First Aid:EYES/SKIN: IMMEDIATELY FLUSH W/COPIOUS AMOUNTS OF WATER FOR
NEEDED. INGESTION: RINSE MOUTH OUT W/WATER IF CONSCIOUS. OBTAIN
MEDICAL ATTENTI ON IN ALL CASES.
* Fire Fighting Measures *
Lower Limits:1.8
Upper Limits:6.9
Extinguishing Media:CO2, DRY CHEMICAL POWDER, APPROPRIATE FOAM. WATER
MAY BE EFFECTIVE FOR COOLING, BUT MAY NOT EFFECT EXTINGUISHMENT.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING. USE WATER SPRAY TO COOL FIRE-EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:COMBUSTIBLE LIQUID. VAPOR MAY TRAVEL TO
DISTANT IGNITION SOURCE & FLASH BACK. CONTAINER EXPLOSION MAY OCCUR
DURING FIRE. FORMS EXPLOSIVE MIXTURES IN AIR.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE AREA & SHUT OFF IGNITION SOURCES.
CARBON ABSORBENT, TAKE UP & PLACE IN CLOSED CONTAINERS. TRANSPORT
OUTDOORS. VENTILATE AREA & WASH SITE AFTER MATERIAL PICKUP IS
COMPLETE.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL DRY PLACE. KEEP
TIGHTLY CLOSED & AWAY FROM HEAT & OPEN FLAME.
Other Precautions:DON'T BREATHE VAPOR. AVOID CONTACT W/EYES, SKIN &
CLOTHING. USE NON-SPARKING TOOLS.
* Physical/Chemical Properties *
Vapor Pres:<1
Vapor Density:4
Appearance and Odor:COLORLESS LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING/REDUCING AGENTS, STRONG BASES.
Stability Condition to Avoid:HEAT, OPEN FLAME & OTHER IGNITION SOURCES.
Hazardous Decomposition Products:CO & CO2.
* Disposal Considerations *
Waste Disposal Methods:THIS COMBUSTIBLE MATERIAL MAY BE BURNED IN A
CHEMICAL INCINERATOR EQUIPPED W/AN AFTERBURNER & SCRUBBER
IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:RUBBER BOOTS AND OTHER PROTECTIVE CLOTHING,
SAFETY SHOWER AND EYE BATH
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER USE AND BEFORE
EATING, DRINKING, SMOKING OR USING SANITARY FACILITIES .
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:STANNANE, DIBUTYL BIS (LAUROYLOXY) (DIBUTYL TIN DILAURATE,
OSHA PEL:0.1 MG/M3, S (SN)
ACGIH TLV:0.1 MG/M3, S (SN)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF SWALLOWED, INHALED, OR
ABSORBED THROUGH SKIN. MATERIAL IS EXTREMELY DESTRUCTIVE TO TISSUE
OF THE MUCOUS MEMBRANES AND UPPER RESPIRATORY TRACT, EYES AND SKIN.
INHALATION MAY BE FATAL AS A RE SULT OF SPASM, INFLAMMATION AND
EDEMA OF THE LARYNX AND BRONCHI, CHEMICAL PNEUMONITIS AND PULMONARY
EDEMA.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:MAY INCLUDE BURNING SENSATION, COUGHING,
WHEEZING, LARYNGITIS, SHORTNESS OF BREATH, HEADACHE, NAUSEA AND
VOMITING.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:EYES/SKIN: IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF WATER
ASSURE ADEQUATE FLUSHING OF EYES BY SEPARATING THE EYELIDS WITH
FINGERS. INHAL: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN.
CALL MD. WASH CONTAMINATED CLOTHING BEFORE REUSE. INGEST: CALL MD
IMMEDIATELY .
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:WATER SPRAY, CO*2, DRY CHEMICAL POWDER, ALCOHOL OR
POLYMER FOAM
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT TO PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE AREA. WEAR NIOSH/MSHA APPROVED SCBA,
HOLD FOR WASTE DISPOSAL. AVOID RAISING DUST. VENTILATE AREA AND
WASH SPILL SITE AFTER MAT ERIAL PICKUP IS COMPLETE.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:DO NOT BREATHE DUST. READILY ABSORBED
THROUGH SKIN. KEEP TIGHTLY CLOSED. STORE IN A COOL, DRY PLACE.
Other Precautions:TOXIC. CORROSIVE. AVOID PROLONGED OR REPEATED
EXPOSURE.
* Physical/Chemical Properties *
HCC:C2
Appearance and Odor:
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG BASES.
Stability Condition to Avoid:
Hazardous Decomposition Products:TOXIC FUMES OF: CO, CO*2, TIN/TIN
OXIDES
* Disposal Considerations *
Waste Disposal Methods:DISSOLVE OR MIX THE MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. DISPOSE I/A/W FEDERAL, STATE AND LOCAL
LAWS.
| 1 | eyes_protection_mandatory |
Control Measures
*
*
Preparer Co. when other than Responsible Party Co.
*
*
Contractor Summary
*
*
Ingredients
*
------------------------------
-----------------------------
IC=INTENDED CHANGES
% Wt: <1
OSHA PEL: 1 MG/CUM
ACGIH TLV: 1 MG/CUM=IC
------------------------------
% Wt: <1
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES: IRRITATION. SKIN: IRRITATION, BURNS. INHALATION:
NOSE & THROAT IRRITATION. NAUSEA, DIZZINESS, HEADACHES. INGESTION:
HARMFUL OR MODERATELY TOXIC, WITH SIMILAR EFFECTS OF INHALLATION.
Explanation Of Carcinogenicity: NONE
First Aid: INGESTION: INDUCE VOMITING. INHALATION: REMOVE TO FRESH AIR. SKIN:
ATTENTION IN ALL CASES.
*
Handling and Disposal
*
Spill Release Procedures: ELIMINATE ALL SOURCES OF IGNITION. VENTILATE AREA.
SOAK UP W/ABSORBENT MATERIAL & STORE IN A CLOSED CONTAINER UNTIL
DISPOSAL.
Waste Disposal Methods: INCINERATE MATERIAL AS A FLAMMABLE LIQUID IN ACCORDANCE
W/LOCAL, STATE, & FEDERAL REGULATIONS.
SPARKS & OPEN FLAME. FOLLOW ALL PERSONAL PROTECTION DIRECTIONS.
*
Fire and Explosion Hazard Information
*
Flash Point Method: SCC
Lower Limits: 3%
Extinguishing Media: CO2, FOAM, DRY CHEMICAL.
*
*
Ventilation: ADEQUATE VENTILATION TO KEEP CONCENTRATIONS BELOW TLV.
*
Physical/Chemical Properties
*
Solubility in Water: SLIGHT
Appearance and Odor: BLUE LIQUID; ALCOHOLIC ODOR.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: HEAT, SPARKS, OPEN FLAMES & OTHER IGNITION
SOURCES
Materials To Avoid: STRONG OXIDIZERS
Hazardous Decomposition Products: CO & CO2
Hazardous Polymerization Indicator: NO
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Company Name: LOCTITE CORP AUTOMOTIVE AND CONSUMER GROUP
Label Required IND: Y
Status Code: C
Origination Code: G
Hazard And Precautions: EYES: IRRITATION. SKIN: IRRITATION, BURNS. INHALATION:
NOSE & THROAT IRRITATION. NAUSEA, DIZZINESS, HEADACHES. INGESTION:
HARMFUL OR MODERATELY TOXIC, WITH SIMILAR EFFECTS OF INHALLATION.
N/K
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHEN SPRAYING/APPLYING IN ANY CIRCUSTANCES
LIKELY TO PRODUCE AIRBORNE LEVEL IN EXCESS OF TLV USE ORG VAPRO
CARTRIDGE OR AIR-SUPPLIED RESPIRATOR.
Ventilation:GENERAL VENTI TO MAINTAIN VAPORS BELWO TLV/PEL.
Other Protective Equipment:SAFETY SHOWERS,EYE BATH,WASHING FACILITIES
SHOULD BE AVAILABLE.
Work Hygienic Practices:WASH CONTAM CLOTHING BEF REUSE.WASH THOROUGHLY
AFT USING.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:METHYL N-AMYL KETONE
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHYL-3-ETHOXYPROPIONATE
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:BENZOTRIAZOLE DERIVATIVE
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMORPHOUS SILICA
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: 1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TITANIUM DIOXIDE
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:LIVER/KIDNEY
DMG.INGEST:DISTRUBANCE IN MEMORY,THINKING
ABILITY,EMOTIONS,COORDINATION.
Explanation of Carcinogenicity:PER MSDS:TOLUENE KNOWN BY STATE OF CA TO
CAUSE REPRODUCTIVE TOXICITY.
Effects of
Overexposure:EYE:SWELLING,BURNING,TEARING,REDDENING.SKIN:DRY8ING,CR
ACKING,DERM.INHAL:CNS EFFECTS,UNCONSC,DIZZ,DROWSINESS,NAU,HEADACHE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
W/SOAP/WATER.DO NOT USE SOLVENTS.REMOVE CONTAMIN CLOTHING.GET MED
ATTN.INHAL:REMOVE TO FRESH AIR.GET MED ATTN.INGEST:GET MED ATTN.
* Fire Fighting Measures *
Flash Point Method:SCC
Autoignition Temp:Autoignition Temp Text:NP
Extinguishing Media:CARBON DIOXIDE,DRY CHEMICAL,FOAM.
Fire Fighting Procedures:WATERSPRAY MAY BE INEFFECTIVE.WEAR NIOSH/MSHA
APPROVED SCBA & PROTECTIVE CLOTH TO PREVENT CONTACT W/SKIN/EYES.
Unusual Fire/Explosion Hazard:VAP MAY ACCUMULATE & FORM EXPLO MIXTURES
W/AIR.CAN FLASH BACK FRM LONG DISTANCES.CLSD CNTNR MAY EXPLO WHEN
EXPO TO EXTREME HEAT.
* Accidental Release Measures *
Spill Release Procedures:PROTECT FROM IGN.WEAR AIR-SUPP RESP FOR
UNVENTI SPILL.COVER W/ABSORBENT MATL.SCOOP INTO CNTNR.CLEAN RESIDUE
W/SUITABLE SOLVENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP TIGHTLY CLSD.ISOLATE FROM
Other Precautions:EMPTY DRM MAY CONTAIN EXPLO VAPORS.DONT
CUT/PUNCTURE/WELD ON/NEAR DRUM.VAPORS ARE HEAVIER THAN AIR & MAY
COLLECT INTO LOW/CONFINED AREAS.
* Physical/Chemical Properties *
HCC:F4
Melt/Freeze Pt:M.P/F.P Text:NP
Decomp Temp:Decomp Text:NP
Vapor Pres:NP
Vapor Density:>1
pH:NP
Viscosity:NP
Evaporation Rate & Reference:N/AVAI
Solubility in Water:NP
Appearance and Odor:BLUE LIQUID, SOLVENT ODOR.
Corrosion Rate:NP
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE RECOGNIZED.
Stability Condition to Avoid:NONE RECOGNIZED.
Hazardous Decomposition Products:CARBON DIOXIDE & CARBON MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:IAW ALL LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:OPEN ALL DOORS AND WINDOWS. EXPOSURES ABOVE THE
TLV OR PEL REQUIRE A NIOSH/MSHA APPROVED RESPIRATOR EQUIPPED FOR
THE EXPOSURE OR SUITABLE NIOSH/MSHA APPROVED RESPIRATORY PROTECTION
Ventilation:LOCAL EXHAUST AND MECHANICAL VENTILATION IF AVAILABLE.
Other Protective Equipment:NONE.
Work Hygienic Practices:USE COMMON SENSE & CARE AROUND CHEMICALS. NEVER
MIX CHEMICALS. CONSULT SUPERVISOR FOR OTHER PRACTICES. ALL (SUPDAT)
Supplemental Safety and Health
HYGIENE PRACT: PRACTICES DEPEND ON SPECIFIC BUSINESS. DIRECTIONS FOR
USE ARE NORMALLY FOUND ON LABEL WHICH WILL DICTATE ENGINEERING AND
CONTROL MEASURES.
* Product Identification *
CAGE:REFRG
CAGE:REFRG
* Composition/Information on Ingredients *
Ingred Name:NON-HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: BURNING IRRITATION. SKIN: SLIGHT
IRRITATION. INGESTION: NAUSEA. INHALATION: NOT EXPECTED TO BE A
PROBLEM.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:SAME AS HEALTH HAZARDS.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
OXYGEN/ARTIFICIAL RESPIRATION) . EYES: FLUSH WITH WATER FOR AT
SOAP AND WAT ER. INGEST: DRINK LARGE AMOUNTS OF WATER TO DILUTE.
CALL MD.
* Fire Fighting Measures *
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:SOAK UP WITH INERT, ABSORBENT MATERIAL. SCOOP
UP AND PLACE IN A PROPER WASTE DISPOSAL CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE, OUT OF
Other Precautions:KEEP OUT OF REACH OF CHILDREN. FOLLOW DIRECTIONS ON
THE CONTAINER FOR PROPER USE OF THIS PRODUCT. NOT INTENDED FOR
INTERNAL CONSUMPTION. NOT EXPECTED TO PRESENT A HAZARD UNDER
ANTICIPATED CONDITIONS O F USE.
* Physical/Chemical Properties *
Solubility in Water:COMPLETE
Appearance and Odor:BLUE; BLAND ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH STATE AND LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF ENGINEERING CONTROLS DO NOT MAINTAIN AIRBORNE
CONCENTRATIONS BELOW TLV/PEL, A NIOSH-APPROVED ORGANIC VAPOR, ACID
GAS RESPIRATOR MUST BE WORN. A PROGRAM SHOULD BE INSTITUTED TO
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:SAFETY SHOWER AND EYE WASH FOUNTAIN SHOULD
BE LOCATED NEARBY. WEAR APPROPRIATE PROTECTIVE CLOTHING FOR RISK OF
EXPOSURE.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH BEFORE EATING OR DRINKING.
Supplemental Safety and Health
ECOLOGICAL INFORMATION:A HIGH BIOCHEMICAL OXYGEN DEMAND, A HIGH
POTENTIAL TO AFFECT SOME AQUATIC ORGANISMS. AFTER DILUTION WITH
LARGE AMOU NT OF WATER, FOLLOWED BY SECONDARY WASTE TREATMENT, IT
IS NOT EXPECTED TO CAUSE ADVERSE ENVIRONMENTAL EFFECTS.
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:ACETIC ACID (CERCLA)
Other REC Limits:NONE RECOMMENDED
Ingred Name:1-PHENYL-3-PYRAZOLIDONE/PYRAZOLIDINONE
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
Ingred Name:NONIONIC SURFACTANT(DETERGENT)
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:5-NITRO-1H-INDAZOLE/5-NITROINDAZOLE
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SEVERE IRRITATION, SEVERE BURNS, PAIN, TEARING,
COUGHING, NAUSEA, VOMITING, DIARRHEA, BLOOD, TESTICULAR, AND
REPRODUCTIVE EFFECTS (ANIMAL STUDIES)
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION MAY BE
MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.
* First Aid Measures *
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:MOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:IMMEDIATELY FLUSH WITH
CLOTHING. ORAL:DO NOT INDUCE VOMITING. IF CONSCIOUS, DRINK A GLASS
OF WATER. CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY.
* Fire Fighting Measures *
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, ALCOHOL FOAM, WATER
SPRAY. USE WATER SPRAY TO KEEP FIRE-EXPOSED CONTAINERS COOL.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. HAZARDOUS DECOMPOSITION
PRODUCTS MAY BE FORMED.
Unusual Fire/Explosion Hazard:FLAMMABLE AND CORROSIVE.
* Accidental Release Measures *
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENTS. VENTILATE AREA.
REMOVE IGNITION SOURCES. NEUTRALIZE WITH BAKING SODA. ABSORB WITH
VERMICULITE. PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN SURFACE
THOROUGHLY. PREVENT RU NOFF FROM ENTERING DRAINS, SEWERS OR
STREAMS.
Neutralizing Agent:SODIUM BICARBONATE
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN COOL, VENTILATED PLACE, AWAY FROM INCOMPATIBLE MATERIALS AND
SOUCES OF IGNITION.
Other Precautions:KEEP THIS AND ALL CHEMICALS OUT OF REACH OF CHILDREN.
THIS PRODUCT FOR INDUSTRIAL USE ONLY. AVOID BREATHING VAPORS OR
MISTS. DO NOT GET IN EYES, ON SKIN OR ON CLOTHING. WASH THOROUGHLY
AFTER HANDLING. LAUNDER CONTAMINATED CLOTHING.
* Physical/Chemical Properties *
HCC:F6
NRC/State Lic Num:NOT RELEVANT
pH:2.0
Solubility in Water:COMPLETE
Appearance and Odor:AMBER LIQUID - VINEGAR ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, BASES
Stability Condition to Avoid:FLAMES AND OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN
* Disposal Considerations *
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL IS SUBJECT TO
FEDERAL, STATE OR LOCAL REGULATIONS. FLUSH TO SEWER WITH LARGE
AMOUNT OF WATER, IF ALLOWED. SINCE EMPTIED CONTAINERS RETAIN
PRODUCT RESIDUE, FOLLOW LABEL WARNINGS EVEN AFTER CONTAINER IS
EMPTIED.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT REQUIRED WITH GOOD INDUSTRIAL VENTILATION.
Ventilation:LOCAL EXHAUST RECOMMENDED, MECHANICAL ACCEPTABLE.
Other Protective Equipment:AS NEEDED TO PROTECT SKIN AND CLOTHING.
Supplemental Safety and Health
KEY1;T6.
* Product Identification *
Kit Part:Y
Preparer's Name:KEN DECOSTA
* Composition/Information on Ingredients *
Ingred Name:N-BUTYL GLYCIDYL ETHER (BGE)
Other REC Limits:NONE SPECIFIED
Ingred Name:SILICA, AMORPHOUS (FILLER PARTICLES ARE THOROUGHLY WETTED
BY VEHICLE SO AIRBORNE EXPOSURE DOES NOT OCCUR UNLESS CURED *
Other REC Limits:NONE SPECIFIED
Ingred Name:*MATERIAL IS SUBSEQUENTLY GROUND, MACHINED OR SANDED).
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SKIN IRRITATION AND POSSIBLE
ALLERGIC REACTIONS. PROLONGED AND REPEATED CONTACT MAY CAUSE
SENSITIZATION WHICH WILL RESULT IN ALLERGIC REACTIONS.
Explanation of Carcinogenicity:N/K OBSERVE CAUTIONS MAY RESULT IN
EXCESSIVE HEAT BUILD-UP WITH THE RELEASE OF TOXIC GASES.
Effects of Overexposure:SKIN RASH/IRRITATION.
* First Aid Measures *
First Aid:FLUSH SKIN AND EYE CONTACT WITH PLENTY OF WATER. WASH SKIN
THOROUGHLY WITH SOAP AND WATER, RUBBING ALCOHOL OR HAND CLEANER. DO
NOT USE SOLVENTS. REMOVE SOILED CLOTHING AND WASH BEFORE RE- USE.
IF IRRI TATION PERSISTS, SEE PHYSICIAN.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:.4
Upper Limits:1.3
Extinguishing Media:DRY CHEMICAL OR HALON FIRE EXTINGUISHER, WATER
SPRAY, FOAM OR FOG.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS WHEN
FIGHTING FIRES IN CONFINED AREAS.
Unusual Fire/Explosion Hazard:DENSE SMOKE AND TOXIC GASES MAY BE
LIBERATED.
* Accidental Release Measures *
Spill Release Procedures:SCRAPE UP AND TRANSFER TO METAL CONTAINER.
WIPE UP REMAINING RESIDUE WITH SOLVENTS, OBSERVING SOLVENT
FLAMMABILITY CAUTIONS OR USE DETERGENT.
*Handling and Storage *
Handling and Storage Precautions:KEEP COOL IN ACCORDANCE WITH LABEL
INSTRUCTIONS.
Other Precautions:FOLLOW RECOMMENDED CURING SCHEDULE.
* Physical/Chemical Properties *
HCC:B2
Vapor Pres:<2
Vapor Density:3.8
Evaporation Rate & Reference:>1
Solubility in Water:<1%
Appearance and Odor:TRANSLUCENT, THIXOTROPIC LIQUID WITH SWEET,
PLEASANT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG LEWIS OR MINERAL ACIDS.
Hazardous Decomposition Products:CO, NOX, ALDEHYDES, ACIDS AND
UNDETERMINED ORGANICS.
Conditions to Avoid Polymerization:AVOID MIXING RESIN/CURING AGENT IN
BATCHES >1LB. DO NOT HEAT MAT'L UNLESS CURING SURFACES TO BE
BONDED. FAILURE TO
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF AS HAZARDOUS WASTE ACCORDING TO DOT
HAZARD CLASS. IF NOT REGULATED BY DOT, DISPOSE OF AS ORM-E.
DISPOSAL METHOD CAN BE LAND BURIAL OR CHEMICAL INCINERATION.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED GAS MASK WITH UNIVERSAL
CANNISTERS TYPE N COLORED RED OR NIOSH/MSHA APPROVED SCBA.
Ventilation:LOCAL AND MECHANICAL EXHAUST RECOMMENDED.
Other Protective Equipment:SAFETY SHOES WHEN HANDLING CYLINDERS,
EYEWASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MATL TO AVOID: FORMALDEHYDE AND ALCOHOLS. ALSO NITROBENZENE, PETROLEUM
AND TOLUENE.
* Product Identification *
Product ID:NITROGEN DIOXIDE IN NITROGEN
* Composition/Information on Ingredients *
Ingred Name:NITROGEN TETROXIDE; (NITROGEN DIOXIDE). PERCENT: 3 PPM -
0.5%.
Fraction by Wt: SEE ING
ACGIH TLV:3 PPM (MFR)
Ingred Name:NITROGEN
Fraction by Wt: BALANCE
ACGIH TLV:ASPHYXIANT
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL WILL CAUSE CONSTRICTION OF THE
THROAT & BRONCHI & EDEMA OF LUNGS. SYMP MAY INCLUDE HDCH,
DIZZINESS, IRRITATION OF NOSE AND THROAT, COUGHING AND BURNING IN
THROAT AND CHEST. MIXTURE WILL ALSO ACT AS AN ASPHYXIANT.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
GIVE ARTF RESP WITH OXYGEN. GET MD IMMED. SKIN/EYE: FLUSH WITH
* Fire Fighting Measures *
Extinguishing Media:USE WHAT IS APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . KEEP FIRE EXPOSED CYLINDERS COOL WITH WATER
SPRAY.
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA. REMOVE LEAKING CYLINDER TO
EXHAUST HOOD OR SAFE OUTDOORS AREA. RED BROWN COLOR OF NO2 WILL
IDENTIFY LARGE LEAKS. CONTACT GAS SUPPLIER FOR FURTHER STEPS IN
HANDLING LEAKS.
Neutralizing Agent:WHEN POSS, NITROGEN DIOXIDE CAN BE NEUT W/EXCESS
*Handling and Storage *
Handling and Storage Precautions:STORE IN A WELL VENTILATED AREA AWAY
FROM SOURCES OF HEAT.
Other Precautions:DO NOT DEFACE CYLINDERS OR LABELS. MOVE CYLINDERS
WITH AN ADEQUATE HAND TRUCK. NO2 MONITORING DEVICE IS ADVISABLE.
KEEP AWAY FROM SOLVENTS, FUELS, LUBRICANTS, COMBUSTIBLES AND
REDUCING AGENTS.
* Physical/Chemical Properties *
HCC:G3
Appearance and Odor:COLORLESS, NO2 HAS A PUNGENT ACRID ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NITROGEN REACTS W/LI, ND & TI AT HIGH TEMPS. NO2 REACTS W/HYDROCARBONS,
ORG DUSTS, CYCLOHEXANE, FLUORINE, (SUPP DATA)
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WHEN HEATED TO DECOMPOSITION OR
REACTED WITH WATER, IT MAY RELEASE TOXIC FUMES.
* Disposal Considerations *
Waste Disposal Methods:ALLOW GAS TO DISCHARGE AT A SLOW RATE. RETURN
DEFECTIVE CYLINDER TO SUPPLIER. WHEN POSSIBLE, NITROGEN DIOXIDE CAN
DISPOSAL MUST BE IN ACCO RDANCE WITH FEDERAL, STATE & LOCAL REGS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:NORMAL AIR DILUTION
Other Protective Equipment:BOOTS & APRON WHEN POURING OR TRANSFERRING
LIQUID.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:W J CORBETT
CAGE:DUBOI
CAGE:DUBOI
* Composition/Information on Ingredients *
Ingred Name:HYDROCHLORIC ACID, HYDROGEN CHLORIDE, MURIATIC ACID
Other REC Limits:7 PPM
OSHA PEL:5 PPM
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: CORROSIVE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES/SKIN: CORROSIVE.
Medical Cond Aggravated by Exposure:SKIN OR RESPIRATORY SENSITIVITY
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH THOROUGHLY
W/WATER. SKIN: FLUSH W/FRESH AIR. WASH W/SOAP & WATER. INGESTION:
GIVE MILK, WATER, EGG WHITES OR A TEASPOON OF MILK OF MAGNESIA.
DON'T INDUCE V OMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:CO2, FOAM
Fire Fighting Procedures:KEEP CONTAINERS COOL.
Unusual Fire/Explosion Hazard:ACIDIC PRODUCT REACTS W/METALS TO PRODUCE
HYDROGEN.
* Accidental Release Measures *
Spill Release Procedures:FLUSH SMALLER AMOUNTS TO DRAIN. IMPOUND &
TREAT LARGE AMOUNTS W/SODIUM BICARBONATE TO COUNTERACT ACIDITY,
DISPOSE RESIDUE TO SOLID WASTE.
Neutralizing Agent:SODIUM BICARBONATE
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL PLACE. KEEP CONTAINER
CLOSED. OPEN BUNGS SLOWLY. DON'T PRESSURE CONTAINER TO EMPTY.
Other Precautions:CAUTIONS ON CONTAINER LABEL.
* Physical/Chemical Properties *
Evaporation Rate & Reference:(N-BU AC = 1): >1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR BROWN LIQUID, ACRID ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CONCENTRATED ALKALIS & METALS
Hazardous Decomposition Products:HYDROGEN CHLORIDE, DICHLORIDE
W/INCOMPLETE COMBUSTION
* Disposal Considerations *
Waste Disposal Methods:PH ADJUSTMENT; NO PHOSPHATES. USE UNTIL LESS
THAN 1 INCH REMAINS IN CONTAINER. EMPTY CONTAINER. TRIPLE RINSE
W/WATER. DISPOSE TO INDUSTRIAL OR SANITARY SEWER. REMOVE OR DEFACE
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:PROVIDE ADEQUATE LOCAL VENTILATION TO MAINTAIN VAPOR
CONCENTRATION BELOW TLV.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Preparer's Name:STEPHEN REPETTO
* Composition/Information on Ingredients *
Ozone Depleting Chemical:1
Ingred Name:TERT-BUTYL ALCOHOL. LEL:2.4%. UEL:8%
Fraction by Wt: 1-3%
Ingred Name:DIAKYL TOLUIDINES; (N,N-DIALKYLTOLUIDINES). LEL:1.2%.
UEL:7%
Fraction by Wt: 1-3%
Fraction by Wt: 1-3%
Ingred Name:2-BENZOTHIAZOLETHIOL; (2-MERCAPTOBENZOTHIAZOLE). LEL:0.2
OZ/FT3 (DUST)
Fraction by Wt: 1-3%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:POSS EYE IRRIT. MOD BY INGEST.
CHLOROCARBON MATLS HAVE PRDCED SENSIT OF MYOCARDIUM TO EPINEPHRINE
IN LAB ANIMALS & COULD HAVE A SIMILAR EFT IN HUMANS. ADRENOMIMETICS
(E.G. EPINEPHRINE) MAY BE CONTRAIN DICATED EXCEPT FOR
LIFE-SUSTAINING USESIN HUMANS ACUTELY/ CHRONICALLY EXPOSED TO
CHLOROCARBONS .(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HEADACHE, NAUSEA, DIZZINESS. NARCOSIS AT HIGH
CONCENTRATION.
Medical Cond Aggravated by Exposure:SKIN DISORDERS, EYE PROBLEMS,
RESPIRATORY, CENTRAL NERVOUS SYSTEM, LIVER, HEART DISEASE &
ALCOHOLISM.
* First Aid Measures *
First Aid:INGEST:DO NOT INDUCE VOMITING. KEEP INDIVIDUAL CALM. OBTAIN
MEDICAL ATTENTION. INHAL:REMOVE TO FRESH AIR. IF SYMPTOMS PERSIST,
OBTAIN MEDICAL ATTENTION. SKIN:FLUSH W/WATER. EYE:FLUSH W/WATER FOR
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:SEE INGREDS
Upper Limits:SEE INGREDS
Extinguishing Media:CARBON DIOXIDE, FOAM & DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
& FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE HCL & PHOSGENE .
* Accidental Release Measures *
Spill Release Procedures:ALLOW TO EVAPORATE W/GOOD VENTILATION. SOAK UP
W/AN INERT ABSORBENT.
Neutralizing Agent:
*Handling and Storage *
BREATHING OF VAPORS. KEEP AWAY FROM EYES.
Other Precautions:NO SMOKING IN AREA OF USE. DO NOT USE IN THE GENERAL
VICINITIY OF ARC WELDING, OPEN FLAMES OR HOT SURFACES. HEAT &/OR UV
RADIATION MAY CAUSE THE FORMATION OF HCL &/OR PHOSGENE .
* Physical/Chemical Properties *
HCC:N1
Vapor Density:4.5
Spec Gravity:1.3
Solubility in Water:SLIGHT
Appearance and Odor:YELLOW LIQUID; SHARP ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
SOLVENT MAY REACT VIOLENTLY W/ALUMINUM ON PROLONGED CONTACT.
Stability Condition to Avoid:
Hazardous Decomposition Products:BY FIRE: TOXIC CHLORIDES. HCL,
PHOSGENE .
* Disposal Considerations *
Waste Disposal Methods:FOLLOW EPA & LOCAL REGULATIONS FOR DISPOSAL OF
CHLORINATED HYDROCARBONS. DISPOSAL MUST BE IN ACCORDANCE W/FEDERAL,
STATE & LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW
APPLICABLE STANDARDS. WHERE RESPIRATORY PROTECTION IS REQUIRED,
USE ONLY NIOSH/MSHA APPROVED RESPIRATORS IN ACCORDANCE WITH OSHA
Ventilation:PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT
BUILD-UP OF VAPORS.
Other Protective Equipment:EYE WASH, SAFETY SHOWER
Supplemental Safety and Health
WT/GAL: 8.0
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:BENZENE
< Wt:.1
OSHA PEL:1 PPM
OSHA STEL:5 PPM (5)
Ingred Name:TITANIUM OXIDE
Minumum % Wt:5.
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT AROM.
Minumum % Wt:1.
Maxumum % Wt:5.
Ingred Name:TRIMETHYLBENZENE
Minumum % Wt:1.
Maxumum % Wt:5.
Ingred Name:DISTILLATES (PETROLEUM), HYDROTREATED LIGHT
Ingred Name:SILICONE MODIFIED ALKYD
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT ALIPH.
Minumum % Wt:5.
Ingred Name:ZINC OXIDE (ZNO)
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:5 MG/M3
Ingred Name:FATTY ACIDS, TALL-OIL, POLYMERS WITH ISOPHTHALIC ACID AND
PENTAERYTHRITOL
Minumum % Wt:5.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:REPORTS HAVE ASSOCIATED REPEATED AND
PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN AND NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING AND INHALING THE CONTENTS MAY BE
HARMFUL OR FATAL.
Explanation of Carcinogenicity:PRODUCTS IN THIS SERIES MAY CONTAIN
BENZENE. IARC, OSHA & NTP HAS DETERMINED THAT THERE IS SUFFICIENT
EVIDENCE FOR CARCINOGENICITY. EXCESSIVE INHALATION OF FUMES MAY
LEAD TO METAL FUME FEVER CHARACTE RIZED BY A METALLIC TASTE IN
MOUTH, EXCESSIVE THIRST, COUGHING, WEAKNESS, FATIGUE, MUSCULAR
PAIN, NAUSEA, CHILLS AND FEVER.
Effects of Overexposure:INHALATION: IRRITATION OF RESPIRATORY TRACT.
PROLONGED INHALATION MAY LEAD TO MUCOUS MEMBRANE IRRITATION,
FATIGUE, DROWSINESS, DIZZINESS AND/OR LIGHTHEADEDNESS. SKIN:
IRRITATION OF SKIN. CAN CAUSE DERMATITIS, DEFATTING, SEVERE SKIN
IRRITATION OR BURNS. EYE: IRRITATION OF EYES. CAN CAUSE BLURRED
VISION, TEARING OF EYES, REDNESS OF EYES, SEVERE EYE IRRITATION,
CORNEAL INJURY. INGESTION: MAY CA USE LUNG INFLAMMATION, FATIGUE,
DROWSINESS, DIZZINESS AND/OR LIGHTHEADEDNESS, UNCOORDINATION,
NAUSEA, VOMITING AND DIARRHEA.
Medical Cond Aggravated by Exposure:INGREDIENTS CONTAINED IN THESE
PRODUCTS HAVE BEEN REPORTED TO AGGRAVATE PREEXISTING EYE, SKIN,
RESPIRATORY, LUNG, ASTHMA-LIKE CONDITIONS, CARDIAC ABNORMALITIES,
KIDNEY, LIVER, NERVOUS SYSTEM DISORDERS.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE AND SUPPORT
BREATHING.HAVE TRAINED PERSON GIVE OXYGEN IF NECESSARY. SKIN:
WASH OFF QUICKLY WITH PLENTY OF WATER, THEN SOAP AND WATER; REMOVE
CONTAMINATED C LOTHING. WASH CONTAMINATED CLOTHING BEFORE REUSE.
EYE: FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF WATER, ESPECIALLY
MEDICAL TREATMENT IMMEDIATELY! IN ALL CASES, SEEK IMMEDIATE
MEDICAL ATTENTION!
* Fire Fighting Measures *
Extinguishing Media:DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:WATER MAY BE USED TO COOL AND PROTECT EXPOSED
CONTAINERS. FIREFIGHTERS SHOULD USE FULL PROTECTIVE CLOTHING, EYE
PROTECTION, AND SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT OR FIRE. VAPORS MAY IGNITE EXPLOSIVELY AT
AMBIENT TEMPERATURES. VAPORS ARE HEAVIER THAN AIR AND MAY TRAVEL
LONG DISTANCES TO A SOURCE OF IG NITION AND FLASH BACK. MAY
DECOMPOSE UNDER FIRE CONDITIONS EMITTING IRRITANT AND/OR TOXIC
GASES.
* Accidental Release Measures *
Spill Release Procedures:COMPLY WITH ALL APPLICABLE HEALTH AND
ENVIRONMENTAL REGULATIONS. VENTILATE AREA WITH EXPLOSION PROOF
EQUIPMENT. SPILLS MAY BE COLLECTED WITH NONCOMBUSTIBLE ABSORBENT
MATERIALS. ELIMINATE ALL SOURCES OF IGNITION. EVACUATE ALL
UNNECESSARY PERSONNEL. TOXIC TO FISH. USE NON-SPARKING TOOLS.
*Handling and Storage *
HEAT, SPARKS AND OPEN FLAME. DO NOT STORE IN ALUMINUM CONTAINERS.
Other Precautions:USE ONLY WITH ADEQUATE VENTILATION. DO NOT TAKE
INTERNALLY. KEEP OUT OF REACH OF CHILDREN. AVOID CONTACT WITH SKIN
AND EYES, AND BREATHING OF VAPORS. WASH HANDS THOROUGHLY AFTER
HANDLING, ESPECIALLY B EFORE EATING OR SMOKING. KEEP CONTAINERS
TIGHTLY CLOSED AND UPRIGHT WHEN NOT IN USE.
* Physical/Chemical Properties *
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, REDUCING AGENTS, BASES, AMINES, FREE RADICAL
INITIATORS, METALS.
Stability Condition to Avoid:ELEVATED TEMPERATURES, CONTACT WITH
OXIDIZING AGENT, OXYGEN FREE ATMOSPHERE, CONTAMINATION.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF SILICON, MONOMER VAPORS.
* Toxicological Information*
Toxicological Information:EXPOSURE TO MATERIALS IN THESE PRODUCTS HAVE
BEEN ASSOCIATED WITH POSSIBLE CARDIAC ABNORMALITIES, BLOOD
ABNORMALITIES, LIVER DAMAGE, KIDNEY DAMAGE. EXCESSIVE INHALATION
OF SOLVENT VAPORS UNDER UNCONT ROLLED CONDITIONS MAY LEAD TO
UNCONSCIOUSNESS, RESPIRATORY FAILURE, ASPHYXIATION, AND EVEN DEATH.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
* MSDS Transport Information *
* Regulatory Information *
Federal Regulatory Information:CERCLA: BENZENE, ZINC OXIDE
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SELF-CNTND BRTHNG APPARAT.OR RESPIRATOR
W/MERCURY CARTRIDGE.
Ventilation:LOCAL EXHAUST OR BREATHING PROTECTION;VENTIL ALONG FLOOR
Supplemental Safety and Health
STOMACH;STARCH-RETENTION ENEMAS FOR DIARRHEA;ANTIDOTE:DIMERCAPROL,
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:MERCURY (SARA III)
OSHA PEL:S, C, 0.1 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Effects of Overexposure:CNTCT DOCTR;INHAL:SORE
THROAT,HEADACHE,NAUSEA;SKIN:REDNESS;EYES:IRRITATION;INGEST:VOMIT,DI
ARRHEA
* First Aid Measures *
First Aid:INHAL:FRESH AIR,REST;SKIN:REMOVE CONTAMIN.CLOTHES,RINSE SKIN
W/PLENTY OF WATER OR SHOWER & WASH SKIN W/WATER & SOAP;EYES:RINSE
WITH PLENTY OF WATER;INGEST:GASTRIC LAVAGE-5% SODIUM FORMALDEHYDE
SULFOXY LATE SOLN.,THEN 2% SODIUM (SEE SUPP DATA)
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:MERCURY IS NOT COMBUSTIBLE.
Unusual Fire/Explosion Hazard:YIELDS EXPLOSV.SOLID ON PROLONGED CONTACT
W/AMMONIA,AMINES,ACETYLENE (CMPDS SENSITVE-MECH SHOCK)
* Accidental Release Measures *
Spill Release Procedures:CLEAN-UP IMMED.,USE SUCTION PUMP & ASPIRATOR
BOTTLE W/LONG CAPILLARY TUBE; IN UNACCESSIBLE AREA,TREAT W/CALCIUM
POLYSULFIDE & EXCESS SULFUR;ZINC OR COPPER POWDER CAN ALSO BE USED
OR SPECIAL ABSORBENT - COLLECT CAREFULLY.
*Handling and Storage *
Handling and Storage Precautions:KEEP IN COOL PLACE WITH VENTILATION
ALONG FLOOR;DONOT HANDLE WITH BARE HAND OR SKIN
Other Precautions:PERIODIC MEDICAL EXAM.RECOMMENDED,DEPENDING UPON
DEGREE OF EXPOSURE;INSPECT ROOMS WHERE MERCURY IS HANDLED REGULARLY
WITH AID OF SPECIAL EQUIPMENT.
* Physical/Chemical Properties *
HCC:N1
Vapor Pres:<.1
Vapor Density:7.0
Solubility in Water:NONE
Appearance and Odor:SILVER-WHITE METALLIC LIQUID OR LUSTRE; NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
MOST METALS-FORMS AMALGAMS;AMMONIA;AMINES,ACETYLENE,BROMINE
Stability Condition to Avoid:SITUATIONS WHERE THERMOMETER BREAKS OR
MERCURY SPILLS
Hazardous Decomposition Products:MERCURY VAPORS GIVEN OFF MORE RAPIDLY
AS TEMPERATURE INCREAS
* Disposal Considerations *
Waste Disposal Methods:PLACE MERCURY IN A TIGHTLY,STOPPERED
BOTTLE;DONOT ALLOW ITEM(MERCURY) TO CONTAMINATE AIR OR WATER;WEAR
DISPOSAL REGULATIONS;DISTILL OR RET URN TO MANUFACTURER FOR
RECYCLE.
| 1 | eyes_protection_mandatory |
Control Measures
*
Proprietary Ind: Y
*
Contractor Summary
*
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: ACUTE:INHALATION:IRRITATION OF RESPIRATORY TRACT.
PROLONGED INHALATION MAY LEAD TO MUCOUS MEMBRANE IRRITATION, DROWSINESS,
AND/OR LIGHT-HEADEDNESS, HEADACHE, NAUSEA. SKIN:IRRITATION. PROLONGED OR REPE
ATED CONTACT CAN CAUSE DERMATITIS. EYE:IRRITATION. PROLONGED OR REPEATED
CONTACT CAN CAUSE BLURRED (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: SEE "LR" VERSION ING 8 FOR ADDITIONAL
INFORMATION (FP N).
Signs And Symptions Of Overexposure: HLTH HAZ:VISION, CORNEAL INJURY.
INGESTION:AMOUNTS INGESTED INCIDENTAL TO CONSUMER & INDUST HANDLING ARE
NOT LIKELY TO CAUSE INJURY; HOWEVER, INGESTION OF LARGER AMOUNTS COULD CAUSE
SERIOUS INJURY.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL:REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
HAVE TRAINED PERSON GIVE OXYG IF NEC. GET EMER MED ATTN. SKIN:WASH OFF
QUICKLY W/PLENTY OF WATER, THEN SOAP & WATER; REMOVE CONTAMD CLTHG. WASH
CONTAMD CLTHG BEFORE REUSE. EYE:FLUSH IMMED W/LG AMTS OF WATER, ESPECIALLY
MEDICAL TREATMENT IMMEDIATELY.
*
Handling and Disposal
*
Spill Release Procedures: COLLECT IN CONTAINER FOR DISPOSAL, ACCORDING TO
HEALTH AND ENVIRONMENTAL REGULATIONS. CLEAN UP WITH WATER BEFORE ALLOWING TO
DRY.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
Other Precautions: DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
*
Fire and Explosion Hazard Information
*
Flash Point Text: NON FLAMMABLE
Extinguishing Media: DRY CHEMICAL OR FOAM.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). NON-FLAMMABLE. WATER MAY BE USED TO COOL AND PROTECT
EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard: CLOSED CONTAINERS MAY BURST IF EXPOSED TO
EXTREME HEAT OR FIRE.
*
*
Respiratory Protection: CONTROL ENVIRONMENTAL CONCS BELOW APPLIC STANDARDS.
WHERE RESP PROT IS REQUIRED, USE ONLY NIOSH APPRVD RESPIRATORS IN ACCORDANCE
Ventilation: MAINTAIN ADEQUATE VENTILATION TO ENSURE AIR ENTRY DURING
APPLICATION & DRYING TO PREVENT BUILD-UP OF VAPORS.
Other Protective Equipment: ANSI APPRVD EYE WASH & DELUGE SHOWER (FP N). SKIN
CREAM (IF NEEDED).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: USER OF "L" VERSION OFSHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N).
*
Physical/Chemical Properties
*
Evaporation Rate & Reference: SLOWER/ETHYL ETHER
Solubility in Water: NOT KNOWN
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: ELEVATED TEMPERATURES. CONTACT WITH OXIDIZING
AGENTS.
Materials To Avoid: OXIDIZERS, ACIDS, BASES, AMINES.
Hazardous Decomposition Products: IF INVOLVED IN FIRE (FROM OTHER SOURCES)
COULD CONCEIVABLY RESULT IN RELEASE OF CARBON DIOXIDE & CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Assigned IND: Y
Company Name: MA BRUDER & SONS INC
Label Required IND: Y
Status Code: C
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE:INHALATION:IRRITATION OF RESPIRATORY TRACT.
PROLONGED INHALATION MAY LEAD TO MUCOUS MEMBRANE IRRITATION, DROWSINESS,
AND/OR LIGHT-HEADEDNESS, HEADACHE, NAUSEA. SKIN:IRRITATION. PROLONGED OR PREP
EATED CONTACT CAN CAUSE DERMATITIS. EYE:IRRITATION. PROLONGED OR REPEATED
CONTACT CAN CAUSE BLURRED VISION, CORNEAL INJURY. INGESTION:AMOUNTS INGESTED
INCIDENTAL TO CONSUMER & INDUST HANDLING ARE NOTLIKELY TO CAUSE INJURY;
HOWEVER, INGESTION OF LARGER AMOUNTS COULD CAUSE SERIOUS INJURY.
CHRONIC:CANCER HAZARD. CONATINS MATERIAL WHICH IS LISTED AS AN ANIMAL LUNG
CARCINOGEN (FP N).
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE.
Ventilation:NONE.
Other Protective Equipment:SAFETY TOE SHOES.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:NITROGEN
Other REC Limits:NONE RECOMMENDED
Ingred Name:OXYGEN
Other REC Limits:NONE RECOMMENDED
Ingred Name:ARGON AND OTHER MINOR COMPONENTS
Fraction by Wt: 1%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:AIR IS NONTOXIC. HOWEVER, INHALATION
OF HIGH PRESSURE AIR MAY PRODUCE CENTRAL NERVOUS SYSTEM
DISTURBANCES AND NITROGEN NARCOSIS.
Effects of Overexposure:EXPOSURE TO HIGH PRESSURE AIR MAY PRODUCE
TINGLING OF FINGERS AND TOES, VISUAL AND ACOUSTICAL DISTURBANCES,
ABNORMAL SENSATIONS, IMPAIRED COORDINATION, CONFUSION, MUSCLE
TWITCHING, EPILEPTIFORM SEIZUR ES, NITROGEN NARCOSIS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:FACILITIES AT WHICH AIR IS BREATHED IN HIGH PRESSURE
ENVIRONMENTS SHOULD BE PREPARED TO DEAL WITH ILLNESSES RESULTING
FROM DECOMPRESSION. DECOMPRESSION EQUIPMENT MAY BE REQUIRED.
* Fire Fighting Measures *
Extinguishing Media:NON-FLAMMABLE. USE EXTINGUISHING MEDIA APPROPIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMPRESSED AIR AT HIGH TEMPERATURE CAN
ACCELERATE THE BURNING OF MATERIALS WHICH ARE COMBUSTIBLE AT
ATMOSPHERIC PRESSURE.
* Accidental Release Measures *
Spill Release Procedures:CAUTION SHOULD BE EXERTED FOR NOISE OR INJURY
BY PROPELLED MOTION OF CYLINDER IF LEAKING.
*Handling and Storage *
Handling and Storage Precautions:SECURE CYLINDERS WHEN IN USE.NEVER USE
DIRECT FLAME TO HEAT COMPRESSED GAS CYLINDER.AVOID DRAGGING,ROLLING
OR SLIDING CYLINDERS.USE HAND TRUCK.
Other Precautions:STORE AWAY FROM HEAVY TRAFFIC AND COMBUSTIBLE
MATERIALS. KEEP AWAY FROM HEAT SOURCES, SALT AND CORROSIVE
CHEMICALS. USE PRESSURE REGULATOR WHEN CONNECTING TO LOW PRESSURE
PIPING. USE CHECK VALVE TO PR EVENT BACKFLOW. DO NOT REFILL.
* Physical/Chemical Properties *
HCC:G3
Vapor Density:1.0
Appearance and Odor:GASEOUS AIR IS ODORLESS AND COLORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:AVOID THE USE OF OIL IN SYSTEMS AT FULL
CYLINDER PRESSURE. AVOID HIGH HEAT AND OPEN FLAMES NEAR CYLINDER.
Hazardous Decomposition Products:
* Disposal Considerations *
Waste Disposal Methods:DO NOT ATTEMPT TO DISPOSE OF RESIDUAL AIR IN
COMPRESSED GAS CYLINDERS. RETURN TO MANUFACTURER WITH THE CYLINDER
VALVE TIGHTLY CLOSED, POSITIVE PRESSURE IN THE CYLINDER, AND VALVE
CAP IN PLACE.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
FULL-FACEPIECE AIRLINE RESPIRATOR IN THE POSITIVE PRESSURE MODE
WITH EMERGENCY ESCAPE PROVISIONS.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
AIRBORNE CONCENTRATIONS BELOW THE PERMISSIBLE EXPOSURE LIMITS. USE
PROCESS (SUPDAT)
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
WEAR APPROPRIATE PROTECTIVE CLOTHING TO MINIMIZE CONTACT WITH SKIN
AND TO PREVENT SKIN EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
Supplemental Safety and Health
PHYSICAL AND CHEMICAL PROPERTIES: MOLECULAR FORMULA: NOT AVAILABLE.
VENTILATION, OR OTHER ENGINEERING CONTROLS TO CONTROL AIRBORNE
LEVELS.
* Product Identification *
CAGE:ACR0S
CAGE:ACR0S
* Composition/Information on Ingredients *
Ingred Name:2-DEOXY-D-RIBOSE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NOT AVAILABLE.
Explanation of Carcinogenicity:2-DEOXY-D-RIBOSE - NOT LISTED BY ACGIH,
IARC, NIOSH, NTP OR OSHA.
* First Aid Measures *
MINUTES, OCCASIONALLY LIFTING UPPER AND LOWER LIDS. SKIN: FLUSH
REMOVING CONTAM INATED CLOTHING AND SHOES. INGESTION: DO NOT INDUCE
VOMITING. ALLOW VICTIM TO RINSE HIS MOUTH AND THEN TO DRINK 2-4
CUPFULS OF WATER, AND SEEK MEDICAL ADVICE. INHALATION: REMOVE FROM
EXPOSURE TO FRESH AIR IMMEDIATELY. NOTES TO MD: TREAT
SYMPTOMATICALLY AND SUPPORTIVELY.
* Fire Fighting Measures *
Flash Point:NOT AVAILABLE
Autoignition Temp:Autoignition Temp Text:N/AV
Lower Limits:NOT AVAIL
Upper Limits:NOT AVAIL
Extinguishing Media:IN CASE OF FIRE, USE WATER, DRY CHEMICAL, CHEMICAL
FOAM, OR ALCOHOL-RESISTANT FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:DURING A FIRE, IRRITATING AND HIGHLY
TOXIC GASES MAY BE GENERATED BY THERMAL DECOMPOSITION AND
COMBUSTION. NFPA RATING: NOT PUBLISHED.
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTIVE EQUIPMENT AS
INDICATED IN EXPOSURE CONTROLS, PERSONAL PROTECTION SECTION. CLEAN
UP SPILLS IMMEDIATELY, OBSERVING PRECAUTIONS IN THE PROTECTIVE
EQUIPMENT SECTION. SWEEP U P, THEN PLACE INTO A SUITABLE CONTAINER
FOR DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:AVOID CONTACT WITH EYES, SKIN AND
CLOTHING. AVOID INGESTION OR INHALATION. STORE IN A COOL, DRY
PLACE. KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:USE APPROPRIATE PROCEDURES TO PREVENT OPPORTUNITIES
FOR DIRECT CONTACT WITH SKIN OR EYES AND TO PREVENT INHALATION.
* Physical/Chemical Properties *
Boiling Pt:B.P. Text:NOT AVAILABLE
Decomp Temp:Decomp Text:NOT AVAILABLE
Vapor Pres:NOT AVAILABLE
Spec Gravity:NOT AVAILABLE
pH:NOT AVAILABLE
Viscosity:NOT AVAILABLE
Solubility in Water:SOLUBLE
Appearance and Odor:WHITE POWDER - SLIGHTLY YELLOW; NO ODOR AVAILABLE.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:STABLE UNDER NORMAL TEMPERATURES AND
PRESSURES. AVOID INCOMPATIBLE MATERIALS.
Hazardous Decomposition Products:CARBON MONOXIDE, IRRITATING AND TOXIC
FUMES AND GASES, CARBON DIOXIDE.
Conditions to Avoid Polymerization:HAS NOT BEEN REPORTED.
* Toxicological Information*
Toxicological Information:THE TOXICOLOGICAL PROPERTIES OF THIS MATERIAL
HAVE NOT BEEN INVESTIGATED. SEE ACTUAL ENTRY IN RTECS FOR COMPLETE
INFORMATION.
* Ecological Information *
Ecological:FOR FURTHER INFORMATION, CONTACT ACROS ORGANICS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE AND LOCAL REGULATIONS.
* MSDS Transport Information *
Transport Information:U.S. DOT: SHIPPING NAME: NO INFORMATION
AVAILABLE. HAZARD CLASS; UN NUMBER; PACKING GROUP: N/P. --
I.M.O./I.A.T.A./R.I.D./A.D.R.: SHIPPING NAME; HAZARD CLASS; UN
NUMBER; PACKING GROUP: N/P. -- CANADIA N T.D.G.: SHIPPING NAME: NO
INFORMATION AVAILABLE. HAZARD CLASS; UN NUMBER; PACKING GROUP: N/P.
* Regulatory Information *
Federal Regulatory Information:EUROPEAN/INTERNATIONAL REGULATIONS:
EUROPEAN LABELING I/A/W EC DIRECTIVES: HAZARD SYMBOLS: NOT
CONTACT WITH SKIN AND EYES. WGK (WATER DANG ER/PROTECTION): CAS
LISTED ON THE TSCA INVENTORY.
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED IF GOOD VENTILATION IS MAINTAINED.
WEAR NIOSH/MSHA APPROVED RESPIRATOR FOR CONCENTRATIONS & TYPES OF
AIR CONTAMINANTS ENCOUNTERED.
Ventilation:NORMAL ROOM VENTILATION.
Other Protective Equipment:EYE WASH FACILITY.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPILL PROC:CANNOT BE DECONTAMINATED (I.E., SHOES).
* Product Identification *
POLYMERS
* Composition/Information on Ingredients *
Ingred Name:EPOXY RESIN (MODIFIED)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:MIST OR VAPOR CAN IRRITATE NOSE
& THROAT. EYE:SUBSTANTIALLY IRRITATING TO EYES. SKIN:SUBSTANCE IS
MODERATELY IRRITATING AND CAN CAUSE SUPERFICIAL BURNS AFTER
PROLONGED CONTACT. INGEST:POSSIBLY H ARMFUL IF SWALLOWED.
CHRONIC:PROLONGED OR REPEATED EXPOSURE CAN CAUSE AN ALLERGIC
REACTION.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL:MOVE TO FRESH AIR. GIVE ARTIFICIAL RESPIRATION IF
BREATHING HAS STOPPED. EYE:FLUSH WITH A LARGE AMOUNT OF WATER FOR
SOAP & WATE R. REMOVE AND WASH CLOTHING BEFORE REUSE. NOTE TO
MD:ALLERGIC DERMATITIS OR RESPIRATORY RESPONSE IN SUSCEPTIBLE
INDIVIDUALS MAY BE DELAYED EVEN WEEKS/MONTHS AFTER FREQUENT AND/OR
PROLONGED CONTACT.
* Fire Fighting Measures *
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:DIKE & ABSORB SPILL ON INERT MATL (SAND,
EARTH, ETC.). TRANSFER DIKING MATL TO CNTNRS FOR DISP. WEAR PROT
CLTHG. USE NIOSH/MSHA APPROVED PRESS DEMAND SCBA/AIR MASK FOR LRG
SPILLS IN CONFINED AREA. WAS H CLTHG BEFORE REUSE. DESTROY CLTHG
THAT (SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
STURDY CONTAINERS.
Other Precautions:AVOID ALL SKIN CONTACT. MAY CAUSE AN ALLERGIC
REACTION.
* Physical/Chemical Properties *
HCC:N1
Vapor Density:>1
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK VISCOUS LIQUID
Percent Volatiles by Volume:NEG
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE LIQUID IN APPROVED EQUIPMENT.
LANDFILL OR INCINERATE CONTAMINATED DIKING MATERIAL IN ACCORDANCE
WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
USE NIOSH APPROVED ORGANIC VAPOR CARTRIDGE RESPIRATOR.
Ventilation:USE ROOM VENTILATION SUFFICIENT TO MEET TLV/USE IN A
CHEMICAL HOOD.
Other Protective Equipment:LABORATORY COAT/APRON
Work Hygienic Practices:REMOVE/LAUNDER ALL CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
PH (1% SOLUTION): 5.5-6.5.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:METHANOL (METHYL ALCOHOL), COLUMBIAN SPIRITS
Ingred Name:HYDROGEN PEROXIDE
Fraction by Wt: 4-7%
Other REC Limits:1 PPM
OSHA PEL:1.4 MG/CUM
ACGIH TLV:1.4 MG/CUM
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY IRRITATION.
PROLONGED OVEREXPOSURE MAY CAUSE BLINDNESS/LIVER/KIDNEY DAMAGE.
INGESTION: GI IRRITATION/NERVOUS SYSTEM DEPRESSION. MAY CAUSE
BLINDNESS/LIVER/KIDNEY DAMAGE/DEATH. S KIN: IRRITATION/ABSORPTION.
EYE: IRRITATION/DAMAGE. ABSORPTION MAY CAUSE OPTIC NERVE
DAMAGE/PERMANENT BLINDNNESS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NAUSEA, HEADACHES, DIZZINESS, NARCOSIS,
IRRITATION, SEVERE ABDOMINAL BACK & LEG PAIN.
Medical Cond Aggravated by Exposure:PRE-EXISTING LIVER/KIDNEY
DISORDERS.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. APPLY CPR/OXYGEN IF
NECESSARY. INGESTION: IF RESPONSIVE INDUCE VOMITING BY GIVING SYRUP
OF IPECAC/A TABLE SPOON OF SALT DISSOLVED IN A GLASS OF WARM WATER.
MINS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:6
Extinguishing Media:ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER SPRAY
Fire Fighting Procedures:WEAR SCBA/PROTECTIVE CLOTHING TO PREVENT
CONTACT W/EYES & SKIN. COOL FIRE EXPOSED CONTAINERS W/WATER WELL
AFTER FIRE IS OUT.
Unusual Fire/Explosion Hazard:VERY FLAMMABLE LIQUID. VAPORS ARE HEAVIER
THAN AIR & CAN TRAVEL ALONG SURFACES TO IGNITION SOURCES & FLASH
BACK.
* Accidental Release Measures *
Spill Release Procedures:EXTINGUISH ALL OPEN FLAMES/SPARKS. VENTILATE
AREA. TAKE UP W/AN INERT ABSORBENT & PLACE IN A DISPOSABLE
CONTAINER.
*Handling and Storage *
Handling and Storage Precautions:HANDLE AS A FLAMMABLE/TOXIC LIQUID.
AVOID BREATHING VAPORS, CONTACT W/EYES, SKIN/CLOTHING. KEEP AWAY
FROM HEAT, LIGHT & ALL SOURCES OF IGNITION.
Other Precautions:STORE AT TEMPERATURE/CONDITIONS AS INDICATED ON THE
PRODUCT LABEL. DON'T WEAR CONTACT LENSES IN THE LABORATORY.
* Physical/Chemical Properties *
pH:SUPP
Evaporation Rate & Reference:(BU AC=1): 4.6
Solubility in Water:COMPLETE
Appearance and Odor:WHITE TRANSPARENT LIQUID W/ALCOHOL ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
MOST ORGANIC CHEMICALS, HYPOCHLORITE BLEACHES, REDUCING AGENTS.
Stability Condition to Avoid:LIGHT SPARKS, FLAMES, OTHER SOURCES OF
IGNITION.
Hazardous Decomposition Products:CO, CO2
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/LOCAL, STATE & FEDERAL
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SHOULD BE NEEDED.
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:EYEBATH, WASHING FACILITIES, SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS WELL AFT HNDLG.FOLLOW GOOD
INDUSTRIAL HYGIENE PRACTICE TO MIN EYE/SKIN CONTACT.
Supplemental Safety and Health
OTHER PRECAUT:RELEASED DIR/INDIR INTO ENVIRO NOT EXPECTED TO HAVE
SIGNIFICANT IMPACT.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:WATER
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM CARBONATE
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM BROMIDE
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM BICARBONATE
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM SULFITE
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:EXPECTED TO BE A LOW HAZARD FOR
RECOMMENDED HANDLING. EYES:NO SPECIFIC HAZARD KNOWN. MAY CAUSE
TRANSIENT IRRITATION. SKIN:LOW HAZARD FOR RECOMMENDED HANDLING.
INGEST:EXPECTED TO BE A LOW INGESTHAZARD.
Explanation of Carcinogenicity:PER MSDS:CARCINOGENICITY
CLASSIFICATION:IARC/ACGIH/NTP/OSHA:NONE.
Effects of Overexposure:TRANSIENT EYE IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL:IF SYMPTOMATIC MOVE TO FRESH AIR. GET MED ATTN IF
SYMPTONS PERSIST. EYES:ANY MATL THAT CONTACTS EYE SHOULD BE WASHED
OUT IMMED W/WATER. GET MED ATTN. SKIN:WASH W/SOAP & WATER. GET MED
ATTN IF SY MPTOMS OCCUR. INGEST:DRINK 1-2 GLASSES OF WATER. SEEK
MED ATTN.
* Fire Fighting Measures *
Flash Point:NONE,NON-COMBUST
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:NONE (NON-COMBUSTIBLE).
Unusual Fire/Explosion Hazard:NONE. NON-COMBUSTIBLE LIQUID.
* Accidental Release Measures *
Spill Release Procedures:FLUSH TO SEWER W/LG AMTS OF WATER.OTHERWISE
ABSORB W/VERMICULITE OR OTHER INERT MATERIAL, THEN PLACE IN
CONTAINER FOR CHEMICAL WASTE. CLEAN SURFACE THOROUGHLY TO REMOVE
RESIDUAL CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:USE W/ADEQUATE VENTILATION.KEEP CNTNR
CLOSED.
Other Precautions:MATL MODERATELY ALKALINE AQU SOLN;PROPERTIES:NO
BIOCHEM OXY DEMAND;NO POT TO CAUSE OXY DEPLETION IN AQU SYS;LOW POT
TO AFFECT AQU ORGANISMS & 2ND WASTE TREATMENT MICROBIAL
METABOLISM;MOD POT TO BIOCOC NE.WHEN DIL W/LG AMTS OF WATER
MATL(SUP)
* Physical/Chemical Properties *
HCC:N1
Vapor Density:0.6
pH:9.6
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID, COLORLESS, ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE W/COMMON MATERIALS AND CONTAMINANTS W/WHICH THE MATERIAL MAY
REASONABLY COME INTO CONTACT.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER. HAZ
COMBUST PROD:NONE (NON-COMBUSTIBLE).
* Disposal Considerations *
Waste Disposal Methods:DISCHARGE/TREATMENT/DISPOSAL MAY BE SUBJECT TO
NATIONAL/STATE/LOCAL LAWS. FLUSH TO SEWER W/LG AMTS OF WATER. CHEM
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT NORMALLY NEEDED
Ventilation:LOCAL RECOMMENDED
Other Protective Equipment:NONE
Supplemental Safety and Health
* Product Identification *
Product ID:BIO-PEN P6F-4
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:DICHLORODIFLUOROMETHANE (SARA III)
Ozone Depleting Chemical:1
Ingred Name:SURFACTANTS
Ingred Name:DYE,YELLOW,FLUORESCINE
Ingred Name:ADDITIVES (PROPRIETARY)
* Hazards Identification *
Effects of Overexposure:EXCESSIVE EXPOSURE CAN CAUSE DEFATTING OF SKIN
* First Aid Measures *
THOROUGHLY WITH WATER. INGESTION-DRINK LARGE QUANTITIES OF MILK OR
WATER.INDUCE VOMITING
* Fire Fighting Measures *
Flash Point:N/A/
Extinguishing Media:WATER
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:ARE AEROSOL CANS-MAY EXPLODE WHEN HEATED
* Accidental Release Measures *
Spill Release Procedures:ABSORB ON ABSORBENT MATERIAL & TRANSFER TO
CONTAINER
*Handling and Storage *
Handling and Storage Precautions:NORMAL HANDLING.STORE IN CHEMICAL
STORAGE AREA
Other Precautions:NONE
* Physical/Chemical Properties *
HCC:V2
Spec Gravity:1.0
Appearance and Odor:YELLOW SOLID SUSPENDED IN LIQUID,NO ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:CONTAINER SHOULD BE SUITABLE FOR SHIPMENT TO
DISPOSAL AREA.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF LARGE AMOUNTS ARE USED IN A POORLY VENTILATED
SPACE, USE A CHEMICAL CARTRIDGE RESPIRATOR WITH ORGANIC VAPOR
CARTRIDGE (MSHA AND NIOSH APPROVED) TO PROTECT AGAINST METHYL
ISOBUTYL CARBINOL VAPORS.
Ventilation:LOCAL EXHAUST MAY BE REQUIRED IN CLOSED SPACES. RECOMMENDED
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
Preparer's Name:E. F. CLUFF
CAGE:0KND3
CAGE:0KND3
* Composition/Information on Ingredients *
Ingred Name:METHYL ISOBUTYL CARBINOL
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHYL SILICATE
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLY(BUTYLTITANATE)
Fraction by Wt: 1%
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: NA
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NA
ACGIH TLV:NA
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRITATION AND ANESTHESIA.
CHRONIC: NONE.
Explanation of Carcinogenicity:EXPLANATION: NO.
Effects of Overexposure:IRRITATION OF EYES, SKIN AND UPPER RESPIRATORY
TRACT.
Medical Cond Aggravated by Exposure:EYE, SKIN AND RESPIRATORY DISORDERS
MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
* First Aid Measures *
AND WATER. INHALATION-REMOVE TO FRESH AIR. GIVE OXYGEN IF BREATHING
DIFFICULT. INGESTION-WASH OUT MOUTH WITH WATER. CALL A PHYSICIAN.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1
Upper Limits:5.5
Extinguishing Media:CARBON DIOXIDE,, DRY CHEMICAL POWDER, ALCOHOL FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING TO PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:VAPOR MAY TRAVEL CONSIDERABLE DISTANCE TO
IGNITION SOURCE AND FLASH BACK.
* Accidental Release Measures *
Spill Release Procedures:TAKE UP WITH ABSORBENT MATERIAL. STORE IN
APPROPIATE CONTAINER. AVOID PROLONGED INHALATION OF VAPOR OR
CONTACT WITH LIQUID. WASH RESIDUE WITH LARGE AMOUNTS OF WATER.
Neutralizing Agent:WATER.
*Handling and Storage *
Handling and Storage Precautions:AVOID IGNITION SOURCES: FLAME, SPARKS,
EXTREME HEAT. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:CONTAINS <1% METHYL CHLOROFORM
(1,1,1-TRICHLOROETHANE). FOR DISPOSAL, MATERIAL MAY BE INCINERATED
WITH CARE TAKEN TO PREVENT ENVIRONMENTAL CONTAMINATION.
* Physical/Chemical Properties *
Decomp Temp:Decomp Text:NIF
Vapor Pres:3.7 MM
Vapor Density:3.5
pH:7
Evaporation Rate & Reference:>1 (N-BUTYL ACETATE=1)
Appearance and Odor:COLORLESS LIQUID. PLESANT, SWEET ODOR.
Corrosion Rate:NIF
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACID CHLORIDES AND OXIDIZING AGENTS.
Stability Condition to Avoid:OPEN FLAMES, SPARKS AND EXTREME HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
SILICA AND TITANIA FROM COMBUSTION.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHERE AIR CONTAM CAN EXCEED ACCEPT CRITERIA, USE
NIOSH/MSHA APPRVD RESP PROT EQUIP. RESPS SHLD BE SELECTED BASED ON
APPLIC STDS/ GUIDELINE S.
Ventilation:IF AIRBORNE CONTAM ARE GENERATED WHEN MATL IS HEATED/HNDLD,
SUFFICIENT VENT IN VOL & AIR FLOW PATTERNS SHLD BE (SUPDAT)
Other Protective Equipment:APPROPRIATE USE OF PERSONAL PROTECTIVE
EQUIPMENT.
Work Hygienic Practices:PRUDENT WORK PRACTICES. WASH THOROUGHLY AFTER
HANDLING.
Supplemental Safety and Health
VENT:PROVIDED TO KEEP AIR CONTAM CONC LEVELS <ACCEPT CRITERIA.
ENGINEERING CTLS:FOLLOWING EXPOS CTL TECHNIQUES MAY BE USED TO
EFTIVELY MIN EMPLOYEE EXPOS:LOC EXHST VENT, ENCLSD SYS DESIGN,
PROCESS ISO LATION & REMOTE CTL. THESE TECHNIQUES MAY NOT
NECESSARILY ADDRESS ALL ISSUES PERTAINING TO YOUR OPERATIONS. WE,
(ING 4)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SUPDAT:THEREFORE, RECOM THAT YOU CONSULT W/EXPERTS OF YOUR
CHOICE TO DETERM WHETHER/NOT YOUR PROGRAMS ARE ADEQUATE.
Ingred Name:CARBONIC ACID, CALCIUM SALT (1:1); (CALCIUM CARBONATE
(CACO*3))
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
Fraction by Wt: 1-5%
Ingred Name:TALC POWDER, CONTAINING NO ASBESTOS
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:0.2 FIBERS/CC
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:MAY BE HARMFUL IF INHALED.
VAPOR CAN CAUSE IRRITATION OF NOSE, THROAT & LUNGS. SKIN
ABSORP/INGEST:NOT TOXIC. SKIN/EYES CONT:NOT AN IRRITANT. ING 1 &
ING 3:OVEREXPOSURE MAY CAUSE LUNG DAMAG E. ING 2:OVEREXPOSURE MAY
CAUSE LUNG FIBROSIS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY DISORDERS
MAY BE AGGRAVATED BY EXPOSURE.
* First Aid Measures *
First Aid:INGEST:DILUTE BY DRINKING LG QTYS OF WATER. IMMED CONT POIS
CTL CTR/HOSP EMER ROOM FOR ANY OTHER ADDNL TREATMENT DIRECTIONS.
INHAL:REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTF RESP, PREF
MOUTH-TO-MOUT H. IF BRTHG IS DFCLT, GIVE O2. CALL MD.EYE:FLUSH
SKIN:FLUSH W/ COPIOUS AMTS OF WATER. CALL MD .
* Fire Fighting Measures *
Extinguishing Media:USE WATER SPRAY, DRY CHEMICAL, FOAM OR CO2.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . USE WATER TO KEEP FIRE-EXPOSED CONTAINERS
COOL.
Unusual Fire/Explosion Hazard:WILL NOT BURN UNLESS WATER HAS
EVAPORATED.
* Accidental Release Measures *
Spill Release Procedures:SWEEP (SCOOP) UP AND REMOVE. PREVENT ENTRY
INTO NATURAL BODIES OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED. STORE IN A
COOL, DRY PLACE.
Other Precautions:AVOID BREATHING VAPOR. USE WITH ADEQUATE VENTILATION.
HANDLE I/A/W GOOD INDUS HYGIENE & SAFETY PRACTICES. THESE PRACTICES
INCL AVOIDING UNNEC EXPOS & REMOVAL OF MATL FROM EYES, SKIN &
CLOTHING.
* Physical/Chemical Properties *
HCC:N1
Spec Gravity:1.6
Appearance and Odor:WHITE PUTTY; MILD ACRYLIC ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL, STATE & FEDERAL
REQUIREMENTS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED HEPA RESPIRATOR IF
REQUIRED. WEAR SELF-CONTAINED BREATHING APPARATUS IF REQUIRED FOR
HIGH LEVELS OF CONTAMINATES.
Ventilation:LOCAL EXHAUST SUFFICIENT TO ENTRAIN ALL PARTICULATE
EMISSIONS. HEPA FILTER REQUIRED. NO LEAKS ON PRESSURE SIDE OF FAN.
Other Protective Equipment:USE COVERALLS OR DISPOSABLE CLOTHING.
Work Hygienic Practices:WET WORK TO THE DEGREE POSSIBLE. WASH HANDS
AFTER HANDLING ITEM. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:D. E. BOUDER
* Composition/Information on Ingredients *
Ingred Name:ASBESTOS, CHRYSOTILE
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 FIBERS/CC
Ingred Name:SYNTHETIC RUBBER
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE:MINOR EYS/SKIN IRRITATION.
INGESTION- IRRITATION OF GI TRACT. INHALATION-IRRITATION OF
RESPIRATORY TRACT. CHRONIC: ASBESTOSIS, LUNG CANCER, &
MESOTHELIOMA, ALL OF WHICH ARE DISABLING AND FATAL D ISEASES OF THE
LUNG. INHALATION AND INGESTION OF ASBESTOS FIBERS MAY CAUSE CANCER
OF THE BOWEL.
Explanation of Carcinogenicity:THIS PRODUCT CONTAINS ASBESTOS
Effects of Overexposure:INHALATION: FATIGUE AND SHORTNESS OF BREATH
THAT GETS WORSE WITH TIME AND EVENTUALLY BECOMES DISABLING. EYES:
IRRITATION. SKIN: IRRITATION. INGESTION: MILD STOMACH DISTRESS.
DIARRHEA, VOMITING, AND NA USEA.
Medical Cond Aggravated by Exposure:ASTHMA, EMPHYSEMA, AND TUBERCULOSIS
ARE ALL GENERALLY AGGRAVATED BY EXPOSURE TO ASBESTOS FIBERS.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. SEE DOCTOR. EYES: RINSE
THOROUGHLY WITH SOAP AND WATER. IF IRRITATION PERSISTS, SEE DOCTOR.
INGESTION: DIL UTE WITH WATER. DO NOT INDUCE VOMITING.SEE DOCTOR.
* Fire Fighting Measures *
Flash Point:NOT REQUIRED
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
* Accidental Release Measures *
Spill Release Procedures:VACUUM THE MATERIAL WITH A HEPA FILTERED
VACUUM. THE EQUIPMENT SHALL BE USED & EMPTIED SO AS TO MINIMIZE THE
RE-ENTRY OF ASBESTOS INTO THE WORKPLACE. OTHERWISE, WET THE
MATERIAL WITH WATER & SURFACTAN T AND THEN SHOVEL OR MOP UP
CONTAMINATION.
*Handling and Storage *
Handling and Storage Precautions:ITEM IS NONFRIABLE & WILL NOT SHED
FIBERS IN NORMAL USE AND STORAGE. USED ITEMS SHALL BE WETTED
BEFORE, DURING & AFTER DISASSEMBLY.
Other Precautions:IF IT IS NECESSARY TO CUT OR IMPACT THE ITEM WHILE
INSTALLING IT, WEAR A RESPIRATOR AND PROTECTIVE CLOTHING. USED
ITEMS SHALL BE IDENTIFIED AND DISPOSED OF IN ACCORDANCE WITH ALL
LOCAL, STATE AND FEDE RAL REGULATIONS FOR ASBESTOS.
* Physical/Chemical Properties *
HCC:T6
Solubility in Water:NEGLIGIBLE
Appearance and Odor:FLEXIBLE SHEETING WITH A RUBBER ODOR
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG MINERAL ACIDS, AND STRONG ALKALIS
Stability Condition to Avoid:ACCUMULATIONS OF DUST
Hazardous Decomposition Products:ASBESTOS DUST
* Disposal Considerations *
Waste Disposal Methods:WET THE MATERIAL WITH WATER AND SURFACTANT.
PLACE IN 6 MIL THICK POLYETHYLENE PLASTIC BAG. PLACE THESE BAGS
INTO ANOTHER POLY BAG OR A SAFE PLACE UNTIL IT CAN BE SHIPPED TO AN
APPROVED DISPOSAL SITE. IDENTIFY WITH ASBESTOS CANCER WARNING
LABEL.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:NORMAL
Other Protective Equipment:LAB COAT
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:HUMAN BLOOD CELLS IN SYNTHETIC MEDIUM
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MAY CAUSE TRANSIENT IRRITATION.
SKIN: LOW HAZARD FOR RECOMMENDED HANDLING. INGESTION: MAY BE
HARMFUL IN LARGE QUANTITIES. INHALATION: LOW HAZARD FOR RECOMMENDED
HANDLING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
* First Aid Measures *
First Aid:EYES: WASH W/LARGE AMOUNTS OF WATER/NORMAL SALINE. SKIN: WASH
W/SOAP/MILD DETERGENT & LARGE AMOUNTS OF WATER. INGESTION: WASH OUT
MOUTH W/WATER IF CONSCIOUS. INHALATION: REMOVE TO FRESH AIR. OBTAIN
ME DICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:USE MEDIA SUITABLE FOR THE SURROUNGING FIRE.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NOT CONSIDERED TO BE AN EXPLOSION/FIRE
HAZARD.
* Accidental Release Measures *
VOLUME, ABSORB W/DISPOSABLE TOWELS/ABSORBENT MATERIAL FROM CHEMICAL
SPILL KIT. CONTAIN IN BIOHA ZARD BAG.
Neutralizing Agent:STRONG SOLUTION OF SODIUM HYPOCHLORITE BLEACH.
*Handling and Storage *
Handling and Storage Precautions:MEDICAL DIAGNOSTIC KITS SERONO
MANUFACTURES ARE TO BE REFRIGERATED.
Other Precautions:ALL HUMAN SERUM PRODUCTS SHOULD BE CONSIDERED
POTENTIALLY HAZARDOUS & HANDLED IN THE SAME MANNER AS AN INFECTIOUS
AGENT.
* Physical/Chemical Properties *
Solubility in Water:MISCIBLE
Appearance and Odor:DEEP RED COLORED LIQUID W/NO ODOR
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACID
Stability Condition to Avoid:HEAT
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED HEPA RESPIRATOR IF
REQUIRED. WEAR SELF-CONTAINED BREATHING APPARATUS IF REQUIRED FOR
HIGH LEVELS OF CONTAMINATES.
Ventilation:LOCAL EXHAUST SUFFICIENT TO ENTRAIN ALL PARTICULATE
EMISSIONS. HEPA FILTER REQUIRED. NO LEAKS ON PRESSURE SIDE OF FAN.
Other Protective Equipment:USE COVERALLS OR DISPOSABLE CLOTHING.
Work Hygienic Practices:WET WORK TO THE DEGREE POSSIBLE. WASH HANDS
AFTER HANDLING ITEM. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
MSDS GENERATED BY HMIS TECHNICIAN. MANUFACTURER IS UNKNOWN OR OUT OF
BUSINESS. ITEM ASSUMED TO CONTAIN ASBESTOS BASED ON AVAILABLE
INFORMATION.
* Product Identification *
Product ID:UNKNOWN BRAKE LINING KIT
Preparer's Name:DGSC-SSH
* Composition/Information on Ingredients *
Ingred Name:ASBESTOS, CHRYSOTILE
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 FIBERS/CC
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE:MINOR EYS/SKIN IRRITATION.
INGESTION- IRRITATION OF GI TRACT. INHALATION-IRRITATION OF
RESPIRATORY TRACT. CHRONIC: ASBESTOSIS, LUNG CANCER, &
MESOTHELIOMA, ALL OF WHICH ARE DISABLING AND FATAL D ISEASES OF THE
LUNG. INHALATION AND INGESTION OF ASBESTOS FIBERS MAY CAUSE CANCER
OF THE BOWEL.
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:INHALATION: FATIGUE AND SHORTNESS OF BREATH
THAT GETS WORSE WITH TIME AND EVENTUALLY BECOMES DISABLING. EYES:
IRRITATION. SKIN: IRRITATION. INGESTION: MILD STOMACH DISTRESS.
DIARRHEA, VOMITING, AND NA USEA.
Medical Cond Aggravated by Exposure:ASTHMA, EMPHYSEMA, AND TUBERCULOSIS
ARE ALL GENERALLY AGGRAVATED BY EXPOSURE TO ASBESTOS FIBERS.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. SEE DOCTOR. EYES: RINSE
THOROUGHLY WITH SOAP AND WATER. IF IRRITATION PERSISTS, SEE DOCTOR.
INGESTION: DIL UTE WITH WATER. DO NOT INDUCE VOMITING.SEE DOCTOR.
* Fire Fighting Measures *
Flash Point:NONFLAMMABLE
Extinguishing Media:NONFLAMMABLE. USE WATER FOG, CARBON DIOXIDE, FOAM,
OR DRY CHEMICAL AS REQUIRED FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
* Accidental Release Measures *
Spill Release Procedures:VACUUM THE MATERIAL WITH A HEPA FILTERED
VACUUM. THE EQUIPMENT SHALL BE USED & EMPTIED SO AS TO MINIMIZE THE
RE- ENTRY OF ASBESTOS INTO THE WORKPLACE. OTHERWISE, WET THE
MATERIAL WITH WATER & SURFACTA NT AND THEN SHOVEL OR MOP UP
CONTAMINATION.
*Handling and Storage *
Handling and Storage Precautions:ITEM IS NONFRIABLE & WILL NOT SHED
FIBERS IN NORMAL USE AND STORAGE. USED ITEMS SHALL BE WETTED
BEFORE, DURING & AFTER DISASSEMBLY.
Other Precautions:IF IT IS NECESSARY TO CUT OR IMPACT THE ITEM WHILE
INSTALLING IT, WEAR A RESPIRATOR AND PROTECTIVE CLOTHING. USED
ITEMS SHALL BE IDENTIFIED AND DISPOSED OF IN ACCORDANCE WITH ALL
LOCAL, STATE AND FEDE RAL REGULATIONS.
* Physical/Chemical Properties *
HCC:T6
Solubility in Water:INSOLUBLE
Appearance and Odor:DRY, MOLDED
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG MINERAL ACIDS, AND STRONG ALKALIS
Stability Condition to Avoid:ACCUMULATIONS OF DUST
Hazardous Decomposition Products:ASBESTOS DUST
* Disposal Considerations *
Waste Disposal Methods:WET THE MATERIAL WITH WATER AND SURFACTANT.
PLACE IN 6 MIL THICK POLYETHYLENE PLASTIC BAG. PLACE THESE BAGS
INTO ANOTHER POLY BAG OR A SAFE PLACE UNTIL IT CAN BE SHIPPED TO AN
APPROVED DISPOSAL SITE. IDENTIFY WITH ASBESTOS CANCER WARNING
LABEL.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD VENTILATION (TYPICALLY 4-6 ROOM VOLUMES PER HOUR)
SHOULD BE USED. VENTILATION SHOULD MATCH CONDITIONS.
Other Protective Equipment:RECOMMENDED DECONTAMINATION FACILITIES,
WASHING FACILITIES.
Work Hygienic Practices:USE GOOD INDUSTRIAL HYGIENE PRACTICES.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:JOSEPH PALMERI
* Composition/Information on Ingredients *
Ingred Name:GLYCERINE, 1,2,3,-TRIHYDROXYPROPANE, GLYCEROL, ANHYDROUS
GLYCERINE, GLYCERIN
Ingred Name:WATER
Ingred Name:WATER SOLUBLE ORGANIC COMPOUND
Ingred Name:WATER SOLUBLE ORGANIC SOLVENT
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: WASH OUT IMMEDIATELY
W/WATER. SKIN: WASH W/SOAP & WATER. INGESTION: DRINK 1-2 GLASSES OF
WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, CO2, DRY CHEMICAL.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:USE ABSORBENT MATERIAL TO SOAK UP EXCESS INK.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED.
Other Precautions:KEEP FROM CONTACT W/OXIDIZING MATERIALS.
* Physical/Chemical Properties *
Solubility in Water:MISCIBLE
Appearance and Odor:CYAN, MAGENTA, YELLOW LIQUID W/SLIGHT
SWEET-ALCOHOLIC ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:CO2, CO.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE/LANDFILL, CAN BE INCINERATED WHEN IN
COMPLIANCE W/LOCAL REGULATIONS. DISCHARGE, TREATMENT/DISPOSAL MAY
BE SUBJECT TO FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT NECESSARY NORMALLY
Ventilation:MECHANICAL REQUIRED
Other Protective Equipment:NONE
Work Hygienic Practices:AS REQUIRED
Supplemental Safety and Health
AS DEFINED BY NTP, ARC, OSHA, NIOSH, AND ACGIH, THERE ARE NO HAZARDOUS
INGREDIENTS IN THIS FORMULATION.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:1-METHYL-1-PHENYLETHYL HYDROPEROXIDE (CUMENE HYDROPEROXIDE)
(SARA III)
Fraction by Wt: 5-6%
Ingred Name:TRIALKYLAMINE
Fraction by Wt: 2-3%
OSHA PEL:NOT LISTED
ACGIH TLV:NOT LISTED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE
Effects of Overexposure:MAY CAUSE DERMATITIS ON PROLONGED CONTACT IN
SENSITIVE INDIVIDUALS
* First Aid Measures *
First Aid:INGESTION: DO NOT INDUCE VOMITING. KEEP INDIVIDUAL CALM.
OBTAIN MEDICAL ATTENTION. INHALATION: DOES NOT APPLY. SKIN: FLUSH
WITH WATER AND EYE: FLUSH WITH WATER
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:DNA
Upper Limits:DNA
Extinguishing Media:CO2, FOAM, DRY CHEMICAL
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:SOAK UP IN AN INERT ABSORBENT. STORE IN
PARTLY-FILLED, CLOSED CONTAINER UNTIL DISPOSAL
*Handling and Storage *
SHELF-LIFE. AVOID PROLONGED SKIN CONTACT
Other Precautions:NONE
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:NA
Evaporation Rate & Reference:> 1
Solubility in Water:SLIGHT
Appearance and Odor:RED LIQUID, ODOR-MILD
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:EXCESS HEAT AND STRONG OXIDIZING AGENT
Hazardous Decomposition Products:NONE
Conditions to Avoid Polymerization:POLYMERIZATION IRRITATORS
* Disposal Considerations *
Waste Disposal Methods:BURY OR INCINERATE IN ACCORDANCE WITH EPA &
LOCAL REGULATIONS
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE A NIOSH/MSHA APPROVED RESPIRATOR AS REQUIRED
TO PREVENT OVEREXPOSURE. USE A NIOSH/MSHA APPROVED ATMOSPHERE
SUPPLYING RESPIRATOR FOR ORGANIC VAPOR.
Ventilation:USE EXPLOSION PROOF VENTILATION TO CONTROL VAPOR
CONCENTRATION.
Other Protective Equipment:IMPERVIOUS CLOTHING.
Work Hygienic Practices:WASH W/SOAP & WATER AFTER EACH USE.
Supplemental Safety and Health
EXPLO HAZ:BACK. THERMAL DECOMPOSITION PRODUCTS MAY INCLUDE HCL &
PHOSGENE . EFTS OF OVEREXP:DOSE-RELATED ADVERSE EFTS ON CNS,
HEMATOPOIETIC TISS, BLOOD, KIDNEYS & LIVER, ASSOC W/ ADMIN OF
ETHYLE NE GLYCOL MONOBUTYL ETHER (EGBE). (EXTRACTED FROM DHHS
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:HYDROCARBON PROPELLANT; (PROPANE/ISOBUTANE BLEND)
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
Fraction by Wt: 5%
Ingred Name:BENZIN; (VM&P NAPHTHA)
Fraction by Wt: 3.8%
Ingred Name:ETHANOL, 2-BUTOXY-; (ETHYLENE GLYCOL MONOBUTYL ETHER (EGBE)
Fraction by Wt: 1.3%
Ingred Name:STODDARD SOLVENT; (MINERAL SPIRITS)
Fraction by Wt: 2.3%
Ingred Name:TOLUENE; (TOLUOL) (SARA III)
Fraction by Wt: 1.3%
PPM STEL, C.
OSHA PEL:SEE INGREDIENT NAME
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:LOSS OF COORD & EQUILIBRIUM.
DIZZ, NAUS, HDCH, POSS SKIN & EYE IRRIT. CHRONIC:METABOLIZES TO
OF OCCUP REPRO HAZS. SEEK CONSULTAT ION FROM APPROP HLTH PROFS
CONCERNING HLTH HAZ LIST INFO & SAFE HNDLG & EXPOS RECOMS . (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:METHYLENE CHLORIDE:ANTICIPATED TO BE
CARCINOGEN. (NTP), GROUP 2B(IARC).
Effects of Overexposure:HLTH HAZ:CHLOROCARBON MATLS HAVE PRDCD SENSIT
OF MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS & COULD HAVE SIM EFT IN
HUMANS. ADRENOMIMETICS (E.G., EPINEPHRINE) MAY BE CONTRAINDICATED
EXCEPT FOR LIFE-SUST AINING USES IN HUMANS ACUTELY/CHRONICALLY
EXPOSED TO CHLOROCARBONS . ANIMAL STUDIES CLEARLY DEMONSTRATED
(SUPDAT)
Medical Cond Aggravated by Exposure:INCREASES & SUSTAINS CARBOXY
HEMOGLOBIN LEVELS IN BLOOD, REDUCING O2 CARRYING CAPACITY IN BLOOD.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR. GIVE ARTF RESP. KEEP QUIET & WARM.
DO NOT USE ADRENALIN. EYES:FLUSH CONTACTED AREAS W/ PLENTY OF WATER
WAT ER. IF PERSISTANT GET MD. INGEST:GET PROMPT MED ATTN. DO NOT
GIVE ADRENALIN.
* Fire Fighting Measures *
Flash Point Method:TOC
Lower Limits:1.8%
Upper Limits:9.5%
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD PRESS DEMAND SCBA &
FULL PROT EQUIP . STOP RELS OF MATLS IF POSS. COOL STORAGE CNTNR.
AVOID ACCUM OF UNBURNED MATL. EXCLUDE AIR.
Unusual Fire/Explosion Hazard:EXPANSION OF LIQ & CHANGE OF STATE FROM
LIQ TO VAP WILL ALLOW COMBUST MIXT TO ENCOMPASS LG AREA. VAPS ARE
HVR/AIR & MAY TRAVEL TO IGNIT SOURCE & FLASH (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE SOURCES OF IGNITION. ABSORB LIQUID
OR INERT MATERIAL SUCH AS SAND OR VERMICULITE. PLACE IN LEAK PROOF
CONTAINERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID WATER CONTACT & HIGH
TEMPERATURES IN STORAGE. DO NOT PUNCTURE CANS.
Other Precautions:NO SMOKING IN AREA OF USE. DO NOT USE IN GENERAL
VICINITY OF ARC WELDING, OPEN FLAMES OR HOT SURFACES. HEAT &/OR UV
RADIATION MAY CAUSE FORMATION OF HCL &/OR PHOSGENE .
* Physical/Chemical Properties *
HCC:G8
Solubility in Water:MINIMAL
Appearance and Odor:THIN WHITE LIQUID; TYPICAL PAINT AROMA.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/STRONG OXIDIZING AGENTS.
OPEN FLAME.
Hazardous Decomposition Products:CO, HCL. PHOSGENE .
OXIDIZING MATERIALS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF AS ORDINARY PAINT I/A/W LOCAL, STATE
& FEDERAL REQUIREMENTS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NA
Ventilation:NA
Other Protective Equipment:NA
Work Hygienic Practices:NA
Supplemental Safety and Health
NK
* Product Identification *
Product ID:SAFE WORLD, BLUE MAGIC
* Composition/Information on Ingredients *
Ingred Name:NO HAZARDOUS INGREDIENTS
Fraction by Wt: NA
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NA
Effects of Overexposure:NA
Medical Cond Aggravated by Exposure:NA
* First Aid Measures *
First Aid:EYES: FLUSH W/LARGE AMOUNTS WATER. SKIN: WASH OFF SKIN &
CLOTHING. IF INGESTED, INDUCE VOMITING. GET MEDICAL AID
IMMEDIATELY.
* Fire Fighting Measures *
Flash Point:NONE
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:NA
Fire Fighting Procedures:NA
Unusual Fire/Explosion Hazard:NA
* Accidental Release Measures *
Spill Release Procedures:FLUSH W/WATER. MOP UP & HOLD FOR DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER SEALED WHEN NOT IN USE.
DO NOT STORE AT ELEVATED TEMPERATURES.
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:NOT EST.
Vapor Density:NOT EST.
Evaporation Rate & Reference:AS WATER
Solubility in Water:COMPLETE
Appearance and Odor:BLUE SOLUTION, CITRUS ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NA
Stability Condition to Avoid:NA
Hazardous Decomposition Products:NA
* Disposal Considerations *
Waste Disposal Methods:ANY METHOD IN ACCORDANCE W/APPLICABLE LAWS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:OPEN WINDOW.
Other Protective Equipment:FULL LENGTH CLOTHING TO AVOID PROLONGED &
REPEATED CONTACT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
CAGE:SYNKO
CAGE:0KKF9
CAGE:SYNKO
* Composition/Information on Ingredients *
Ingred Name:NON HAZARDOUS INGREDIENT
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: HYPERSENSITIVE INDIVIDUALS MAY
EXPERIENCE SOME SKIN SENSITIZATION OR IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:CHRONIC:
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:EYES: FLUSH IMMEDIATELY WITH LARGE AMOUNT OF WATER FOR AT
MD IF IRRIT ATION PERSISTS. INGEST: DRINK 1 OR 2 GLASSES OF WATER
TO DILUTE. DO NOT INDUCE VOMITING. CONSULT MD IMMEDIATELY. INHAL:
MOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP) .
* Fire Fighting Measures *
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:
* Accidental Release Measures *
Spill Release Procedures:USE ABSORBENT MATERIAL SUCH AS SAND TO PICK UP
EXCESS, WASH AREA WITH SOAP AND WATER.
Neutralizing Agent:
*Handling and Storage *
PROTECT FROM FREEZING.
Other Precautions:
* Physical/Chemical Properties *
Appearance and Odor:
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:
Hazardous Decomposition Products:OXIDES OF CARBON.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS. BEFORE ATTMPTING CLEAN-UP, REFER TO HAZARD
CAUTION INFORMATION.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:MAY USE ORGANIC CHEMICAL CARTRIDGE RESPIRATOR IF
NEEDED DUE TO POOR VENTILATION.
Ventilation:USE EXHAUST; USE IN WELL VENTILATED AREA.
Other Protective Equipment:APRON IF NEEDED FOR CLOTHING PROTECTION.
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
Preparer's Name:RICHARD ROY
* Composition/Information on Ingredients *
Ingred Name:POLYAMIDE RESIN
Ingred Name:VOC 0 GRAMS/LITER
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Health Hazards Acute and Chronic:SKIN: NOT CONSIDERED TOXIC BY SKIN
ABSORPTION, BUT MAY CAUSE IRRITATION. INGESTION: MAY CAUSE
GASTROINTESTINAL IRRITATION AND BURNS TO MOUTH AND THROAT.
INHALATION: DUE TO THE LOW PRESSURE; NOT CONSID ERED AS A HAZARD.
USE IN WELL VENTILATED AREAS. AVOID PROLONGED OR REPEATED BREATHING
OF VAPOR.
Effects of Overexposure:CAUSES SKIN AND EYE IRRITATION.
* First Aid Measures *
PHYSICIAN. SKIN: WASH MATERIAL FROM SKIN WITH SOAP AND WATER. WASH
CONTAMINATED CLOTHING. INGESTION: DO NOT INDUCE VOMITING. GIVE
LARGE QU ANTITIES OF MILK OR WATER. CALL PHYSICIAN.
* Fire Fighting Measures *
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL OR WATER.
Fire Fighting Procedures:MATERIALS WILL NOT BURN UNLESS PREHEATED. DO
NOT ENTER CONFINED FIRE SPACE WITHOUT FULL BUNKER GEAR WITH
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:OXIDIZER OF NITROGEN AND CARBON FORMED
UPON BURNING.
* Accidental Release Measures *
Spill Release Procedures:ABSORB MATERIAL WITH SAND OR VERMICULITE.
*Handling and Storage *
Handling and Storage Precautions:DO NOT EXPOSE TO EXCESSIVE MOISTURE AS
CONTAMINATION OF THE PRODUCT WILL OCCUR.
* Physical/Chemical Properties *
Vapor Density:<1
pH:7.-7.7
Appearance and Odor:DARK GRAY PASTE, AMINE ODOR.
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
BASES, ACIDS AND OXIDIZERS.
Hazardous Decomposition Products:CARBON MONOXIDE
Conditions to Avoid Polymerization:SUBJECT MATERIAL REQUIRES SEPARATE
RESIN TO EFFECT REACTIVITY THUS, STABLE AS SUPPLIED.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF MATERIAL PER ALL FEDERAL, LOCAL AND
STATE REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIMS BY VENT, WEAR PROPERLY FITTED NIOSH/MSHA APPRVD ORG
VAP/PARTICULATE RESP FOR PROT AGAINST INGS. WHEN SANDING,
WIREBRUSHING, ABRADING, BURNING/W ELDING DRIED FILM, WEAR NIOSH/
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPT IF EXPOS TO INGS IS
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC:TO PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN
EXPOS TO EXTREME HEAT. EXPLO HAZ:REQS SPECIAL PRECS. DURING EMER
CNDTNS OVEREXP TO DECOMP PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE
IMMED APPARENT. OBTAIN MED ATTN. EFTS OF OVEREXP:INTENTIONAL
* Product Identification *
* Composition/Information on Ingredients *
ACGIH TLV:ASPHYXIANT
Fraction by Wt: <5%
Ingred Name:BENZENE, ETHYL-; (ETHYLBENZENE) (SARA III). VP:7.1.
Fraction by Wt: 1%
Ingred Name:XYLENE (SARA III). VP:5.9.
Fraction by Wt: <5%
Fraction by Wt: <5%
Ingred Name:N-BUTYL ALCOHOL; (2-BUTANOL) (SARA III). VP:5.5.
Fraction by Wt: <5%
Ingred Name:2-PENTANONE, 4-METHYL-; (METHYL ISOBUTYL KETONE) (SARA
Fraction by Wt: <5%
Ingred Name:ACETIC ACID, ISOBUTYL ESTER; (ISOBUTYL ACETATE) (SARA
Fraction by Wt: <5%
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (TALC)
Fraction by Wt: 5%
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:SUPDAT:HARMFUL/FATAL. NOTE:TOLUENE APPEARS ON NAVY LIST OF
SAFE HANDLING & EXPOSURE INFO .
Ingred Name:RESP PROT:MSHA APPRVD PARTICULATE RESP FOR PROT AGAINST
NON-VOLATILE MATLS IN INGREDIENT SECTION.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPOS MAY BE BY INHAL &/OR SKIN/EYE
CONT, DEPENDING ON CNDTNS OF USE. TO MIN EXPOS, FOLLOW RECS FOR
PROPER USE, VENT & PERSONAL PROT EQUIP. ACUTE:IRRIT OF EYES, SKIN &
RESP SYS. MAY CAUSE NERV SYS DEP RESS. EXTREME OVEREXP MAY RSLT IN
UNCON& POSS DEATH. HDCH, DIZZ, NAUS & LOSS OF COORD ARE INDICATIONS
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:OF EXCESSIVE EXPOS TO VAPS/SPRAY
MISTS. REDNESS & ITCH/BURNING SENSATION MAY INDICATE EYE/EXCESSIVE
SKIN EXPOS. CHRONIC:PRLNG OVEREXP TO SOLV INGS MAY CAUSE ADVERSE
EFTS TO LIVER, URINARY, BL OOD-FORMING, CVS & REPRO SYS. RPTS
HAVEASSOC RPTD & PRLNG OVEREXP TO SOLVS W/PERM BRAIN & NERV SYS
DMG. (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
* First Aid Measures *
First Aid:INHAL:IF ANY BREATHING PROBLEMS OCCUR DURING USE, LEAVE AREA
& GET FRESH AIR. IF PROBLEMS REMAIN OR OCCUR LATER, IMMEDIATELY GET
MEDICAL ATTENTION. SKIN:WASH AFFECTED AREA THOROUGHLY W/SOAP &
WATER. R EMOVE CONTAMINATED CLOTHING & LAUNDER BEFORE RE-USE.
MEDICAL ATTENTION. INGEST:GET MEDICAL ATTENTION.
* Fire Fighting Measures *
Lower Limits:0.5%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
WATER SPRAY MAY BE INEFT. IF WATER IS USED, FOG NOZZ ARE PREF.
WATER MAY BE USED TO COOL CLSD CNTNRS(SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPKS & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOS TO EXTREME HEAT. APPLICATION TO HOT SURFS(SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE &
REMOVE W/INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DOL STOR CATEGORY - 1A. CONTENTS ARE
EXTREMELY FLAMM. KEEP AWAY FROM HEAT, SPKS & OPEN FLAME. CONSULT
NFPA CODE. USE APPRVD BONDING & GROUNDING PROCS.
Other Precautions:DURING USE & UNTIL ALL VAPS ARE GONE: KEEP AREA
VENTILATED; DO NOT SMOKE; EXTING ALL FLAMES, PILOT LIGHTS &
HEATERS; TURN OFF STOVES, ELEC TOOLS & APPLIANCES & ANY OTHER
* Physical/Chemical Properties *
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF METALS IN INGS.
* Disposal Considerations *
Waste Disposal Methods:WASTE FROM THIS PROD MAY BE HAZ AS DEFINED UNDER
DETERM APPLIC EPA WASTE NUMBERS. DO NOT INCIN. DEPRESSURIZE CNTNR.
DISP OF I/A/W FED, ST ATE & LOC REGS REGARDING POLLUTION.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:PENTAFLUOROPHENYL SULFIDE
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:MAY BE HARMFUL BY INHALATION,
INGESTION OR SKIN ABSORPTION. CAUSES EYE AND SKIN IRRITATION.
MATERIAL IS IRRITATING TO MUCOUS MEMBRANES AND UPPER RESPIRATORY
TRACT. THE CHEMICAL, PHYSICAL AND TOX ICOLOGICAL PROPERTIES HAVE
NOT BEEN THOROUGHLY INVESTIGATED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
SKIN:IMMEDIATELY WASH WITH SOAP & COPIOUS AMOUNTS OF WATER. WASH
CONTAMINATED CLOTHING BEFORE REUSE. INHAL:REMOVE TO FRESH AIR. IF
NOT BRE ATHING GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS
DIFFICULT GIVE OXYGEN. CALL MD. INGEST:CALL MD IMMEDIATELY .
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL POWDER,
ALCOHOL OR POLYMER FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE AREA. WEAR NIOSH/MSHA APPROVED SCBA,
HOLD FOR WASTE DISPOSAL. AVOID RAISING DUST. VENTILATE AREA AND
WASH SPILL SITE AFTER M ATERIAL PICKUP IS COMPLETE.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP
TIGHTLY CLOSED. STENCH.
Other Precautions:DO NOT GET IN EYES, ON SKIN, ON CLOTHING. IRRITANT.
* Physical/Chemical Properties *
Appearance and Odor:
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:
Hazardous Decomposition Products:TOXIC FUMES OF CARBON MONOXIDE, CARBON
DIOXIDE, SULFUR OXIDES, HYDROGEN FLUORIDE.
* Disposal Considerations *
Waste Disposal Methods:DISSOLVE OR MIX THE MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCURBBER. OBSERVE ALL FEDERAL, STATE AND LOCAL
LAWS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR IF PERMISSIBLE
EXPOSURE LEVEL IS EXCEEDED.
Ventilation:RECOMMENDED.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER . APRON MAY BE WORN TO PROTECT CLOTHING.
Work Hygienic Practices:GOOD HOUSEKEEPING PRACTICES SHOULD BE FOLLOWED.
Supplemental Safety and Health
* Product Identification *
INC.
* Composition/Information on Ingredients *
Ingred Name:HYDROTREATED HEAVY NAPHTHA (PETROLEUM); (ISOPARAFFIN)
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH STEL:N/K
Ingred Name:LIGHT ALIPHATIC SOLVENT NAPHTHA (PETROLEUM); (PETROLEUM
NAPHTHA)
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH STEL:N/K
Ingred Name:ISOPROPYL ALCOHOL
= Wt:5.
Other REC Limits:N/K
OSHA STEL:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: SKIN: NON-IRRITATING. EYES:
NON-IRRITATING. INHALATION: MAY CAUSE DIZZINESS AND HEADACHE.
INGESTION: NOT A NORMAL ROUTE OF ENTRY. TARGET ORGANS: NOT
APPLICABLE.
Effects of Overexposure:SEE HEALTH HAZARDS.
* First Aid Measures *
First Aid:SKIN: DISCONTINUE USE IF RASH OR IRRITATION OCCURS. FLUSH
WITH COPIOUS AMOUNTS OF WATER. SEE MD . EYES: FLUSH WITH COLD WATER
INGESTION:DO NOT INDUCE VOMITING. CALL PHYSICIAN.
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:DRY CHEMICAL, FOAM, CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . HANDLE AS FLAMMABLE LIQUID CLASS 4.
Unusual Fire/Explosion Hazard:NOT APPLICABLE.
* Accidental Release Measures *
Spill Release Procedures:ABSORB LARGE SPILLS WITH VERMICULITE OR
EQUIVALENT AND DISPOSE AS FLAMMABLE LIQUID.
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM HEAT AND SOURCES OF
IGNITION.
* Physical/Chemical Properties *
Solubility in Water:NEGLIGIBLE
Appearance and Odor:FABRIC IMPREGNATED WITH COLORLESS LIQUID, WITH
SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:HEAT, SPARKS, FLAMES AND OTHER IGNITION
SOURCES.
Hazardous Decomposition Products:NOT APPLICABLE.
* Disposal Considerations *
Waste Disposal Methods:FOLLOW LOCAL, STATE AND FEDERAL REGULATIONS.
* MSDS Transport Information *
Transport Information:DOT SHIPPING NAME: CONSUMER COMMODITY. TECHNICAL
SHIPPING NAME: NOT APPLICABLE. DOT SHIPPING CLASSIFICATION:
"ORM-D". DOT ID NUMBER: NOT APPLICABLE. DOT LABEL REQUIREMENTS: NOT
APPLICABLE. UN/NA NUMBE R REGULATIONS: NOT APPLICABLE. REPORTABLE
QUANTITY: NOT APPLICABLE.
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE APPROPRIATE OSHA/MSHA APPROVED SAFETY
EQUIPMENT.
Ventilation:THIS CHEMICAL SHOULD BE HANDLED ONLY IN A HOOD.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. CONTACT LENSES SHOULDN'T BE WORN IN THE LABORATORY.
Supplemental Safety and Health
PERSONS NOT SPECIFICALLY/PROPERLY TRAINED SHOULDN'T HANDLE THIS
CHEMICAL/ITS CONTAINER. ALL CHEMICALS SHOULD BE CONSIDERED
HAZARDOUS-AVOID DIRECT PHYSICAL CONTACT. DATA INFORMATION IS FOR
ACETONE.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:5-HYDROXYDICAMBA
Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE
Ingred Name:WATER
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE HARMFUL BY INHALATION,
INGESTION/SKIN ABSORPTION. SEVERE EYE IRRITANT. CAN CAUSE SKIN
IRRITATION. MATERIAL IS IRRITATING TO MUCOUS MEMBRANES & UPPER
RESPIRATORY TRACT. EXPOSURE CAN CAUSE DERMAT ITIS. MAY AFFECT LIVER
& KIDNEYS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
* First Aid Measures *
HAVE OCCURRED, CLEANSE W/SOAP & WATER. INHALATION: REMOVE TO FRESH
AIR. GIVE OXYGEN/CPR IF NEEDED. IF IN SHOCK, KEEP WARM/QUIET.
INGESTION: D ON'T GIVE LIQUID/INDUCE VOMITING IF
UNCONSCIOUS/CONVULSIVE. IF VOMITING, WATCH CLOSELY TO KEEP FROM
AIRWAY OBSTRUCTON. RINSE OUT MOUTH W/WATER IF CONSCIOUS. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point:1.4F
Lower Limits:2.5
Extinguishing Media:CO2, DRY CHEMICAL POWDER/APPROPRIATE FOAM
Fire Fighting Procedures:WATER MAY BE EFFECTIVE FOR COOLING, BUT MAY
NOT EFFECT EXTINGUISHMENT.
Unusual Fire/Explosion Hazard:EXTREMELY FLAMMABLE. VAPORS MAY TRAVEL
CONSIDERABLE DISTANCE TO SOURCE OF IGNITION & FLASHBACK.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE AREA. WEAR OSHA REGULATED EQUIPMENT.
VENTILATE AREA. ABSORB ON VERMICULITE/SIMILAR MATERIAL. SWEEP UP &
PLACE IN AN APPROPRIATE CONTAINER. HOLD FOR DISPOSAL. WASH
CONTAMINATED SURFACES TO REM OVE ANY RESIDUES.
*Handling and Storage *
Handling and Storage Precautions:KEEP TIGHTLY CLOSED. STORE IN A COOL,
DRY PLACE. STORE ONLY W/COMPATIBLE CHEMICALS. THIS PRODUCT IS
FURNISHED FOR LABORATORY USE ONLY.
Other Precautions:AVOID CONTACT W/SKIN, EYES & CLOTHING. DON'T BREATHE
VAPORS. PRODUCT MAY NOT BE USED AS DRUGS, COSMETICS,
AGRICULTURAL/PESTICIDAL PRODUCTS, FOOD ADDITIVES/AS HOUSEHOLD
CHEMICALS.
* Physical/Chemical Properties *
Vapor Density:2
Evaporation Rate & Reference:(BUTYL ACETATE=1): 5.6
Solubility in Water:MISCIBLE
Appearance and Odor:COLORLESS LIQUID W/FRUITY/PLEASANT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
BASES, OXIDIZING AGENTS, REDUCING AGENTS
Stability Condition to Avoid:IGNITION SOURCES
Hazardous Decomposition Products:CO, CO2
* Disposal Considerations *
Waste Disposal Methods:BURN IN A CHEMICALS INCINERATOR EQUIPPED W/AN
AFTERBURNER & SCRUBBER/DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:ADEQUATE VENTILATION.
Other Protective Equipment:EYE WASH AND SAFETY SHOWER.
Work Hygienic Practices:EASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:CARBOXYLATE SALT, TRADE SECRET COMPONENT
Other REC Limits: SPECIFIED
Ingred Name:SODIUM PHOSPHATE, DIBASIC (SARA III)
Other REC Limits: SPECIFIED
Ingred Name:DPD SALT, SALT OF N,N-DIETHYL-P-PHENYLENEDIAMINE
Fraction by Wt: <5%
Other REC Limits: SPECIFIED
Ingred Name:OTHER COMPONENTS (TYPE NOT SPECIFIED)
Fraction by Wt: <1%
Other REC Limits: SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS PRODUCT MAY BE: IRRITATING TO
EYES AND RESPIRATORY TRACT, AND MAY CAUSE ALLERGIC SKIN REACTION.
ACUTE TOXICITY: SLIGHTLY TOXIC. CHRONIC TOXICITY: NOT DETERMINED.
Explanation of Carcinogenicity:NOT DETERMINED.
Effects of Overexposure:OVEREXPOSURE: CONTACT MAY CAUSE IRRITATION,
SKIN SENSITIZATION.
Medical Cond Aggravated by Exposure:ALLERGY OR SENSITIVITY TO SALTS OF
N,N-DIETHYL-P-PHENYLENEDIAMINE.
* First Aid Measures *
PHYSICIAN. REMOVE CONTAMINATED CLOTHING. WASH SKIN WITH SOAP AND
PLENTY OF WATER. INGESTION-GIVE LARGE QUANTITIES OF WATER. CALL
PHYSICIAN IM MEDIATELY. INHALATION-REMOVE TO FRESH AIR.
* Fire Fighting Measures *
Extinguishing Media:WATER, DRY CHEMICAL, ALCOHOL FOAM, OR CARBON
DIOXIDE.
Fire Fighting Procedures: SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard:MAY EMIT TOXIC FUMES IN FIRE.
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP POWDER. AVOID BREATHING MATERIAL.
DISSOLVE IN WATER. FLUSH DOWN THE DRAIN WITH EXCESS WATER.
*Handling and Storage *
Handling and Storage Precautions:AVOID CONTACT WITH EYES. AVOID
PROLONGED OR REPEATED CONTACT WITH SKIN. DO NOT BREATH DUST.
Other Precautions:
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:SOLUBLE
Appearance and Odor:WHITE TO PALE PINK POWDER. NO ODOR. SOLID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:EXTREME TEMPERATURES, EXCESS MOISTURE,
EXPOSURE TO LIGHT.
Hazardous Decomposition Products:MAT EMIT TOXIC FUMES OF PHOSPHORUS
OXIDES IN FIRE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL,
STATE, LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:A RESPIRATOR APPROVED BY NIOSH FOR DUST, FUMES &
MISTS SHOULD BE WORN DURING THE THERMAL SPRAY PROCESS.
Other Protective Equipment:EYE WASH STATION, ALUMINIZED APRON, EAR
PROTECTION WHERE REQUIRED.
Work Hygienic Practices:PRACTICE GOOD HOUSEKEEPING.
Supplemental Safety and Health
THE FOLLOWING LENS SHADES ARE RECOGNIZED FOR THE PROCESS INDICATED.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:GRAPHITE, NATURAL
Ingred Name:SILICON
Ingred Name:MANGANESE (SARA III)
OSHA PEL:(C) 5 MG/M3 DUST
Ingred Name:CHROMIUM (SARA III)
OSHA PEL:1 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:NICKEL (SARA III)
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/M3
Ingred Name:IRON OXIDE
Ingred Name:BORON OXIDE
Ingred Name:COBALT (SARA III)
OSHA PEL:0.1 MG/M3;AS CO
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION, CORONA
CONJUNCTIVITIS, EYELID INFLAMMATION. SKIN: DERMATITIS, IRRITATION.
INHALATION: MUCOUS MEMBRANES/NOSE/THROAT IRRITATION, PARKINSON'S
ASTHENIA, INSOMNIA, MENTAL, METAL FUME FEVE R, TIGHT CHEST,
DYSPNEA, RALES, FIBROSIS.
Explanation of Carcinogenicity:NICKEL IS CONSIDERED TO BE HUMAN A1
CARCINOGEN BY ACGIH. IRON HAS AN EXPERIMENTAL TUMORIGEN/POSSIBLE
CARCINOGEN.
Effects of Overexposure:EYES: IRRITATION, CORONA CONJUNCTIVITIS, EYELID
INFLAMMATION. SKIN: DERMATITIS & IRRITATION. INHALATION: MUCOUS
MEMBRANES/NOSE/THROAT IRRITATION, PARKINSON'S, ASTHENIA, INSOMNIA,
MENTAL, METAL FUME FE VER, TIGHT CHEST, DYSPNEA, RALES, FIBROSIS.
* First Aid Measures *
First Aid:EYES: FLUSH W/AMOUNTS OF WATER. SKIN: WASH W/SOAP & WATER TO
REMOVE POWDER. INHALATION: REMOVE TO FRESH AIR. INGESTION: OBTAIN
MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:USE CLASS D FIRE EXTINGUISHER.
Fire Fighting Procedures:TREAT AS A METALLIC FIRE.
Unusual Fire/Explosion Hazard:MODERATE FIRE HAZARD IN THE FORM OF DUST
WHEN EXPOSED TO FLAME.
* Accidental Release Measures *
Spill Release Procedures:MATERIAL THAT IS SPILLED ONTO THE FLOOR MAY
BECOME AIRBORNE BY NORMAL PLANT ACTIVITY. GOOD HOUSEKEEPING, BY
SWEEPING THE AREA CLEAN, IS NECESSARY TO REMOVE THESE MATERIALS
FROM BECOMING A SOURCE OF AI R CONTAMINATION.
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM INCOMPATIBLES. COOL &
DRY AREA. AVOID ORAL INGESTION & CONTACT W/SKIN.
* Physical/Chemical Properties *
Spec Gravity:3.2
Solubility in Water:NEGLIGIBLE
Appearance and Odor:POWDER; NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACIDS, SULFUR, WOOD, COMBUSTIBLES, OXIDIZERS, NICKEL NITRATE.
Hazardous Decomposition Products:OZONE, NITRIC OXIDE FROM PLASMA FLAME.
* Disposal Considerations *
Waste Disposal Methods:CONSULT LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:AS NECESSARY
Work Hygienic Practices:USE GOOD INDUSTRIAL HYGIENE & SAFETY PRACTICES.
WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:THORIUM NITRATE
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES/SKIN: IRRITATION.
* First Aid Measures *
WASH W/SOAP & WATER. OBTAIN MEDICAL ATTENTION.
* Accidental Release Measures *
Spill Release Procedures:FLUSH TO DRAIN W/WATER.
*Handling and Storage *
Handling and Storage Precautions:AVOID UNNECESSARY EXPOSURE, CONTACT
W/EYES, SKIN & CLOTHING.
* Physical/Chemical Properties *
Vapor Density:1
Spec Gravity:1.0-1.2
Evaporation Rate & Reference:(WATER= 1): 1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR SOLUTION W/NO ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR. IN CONFINED
AREAS, USE NIOSH/MSHA APPROVED AIRLINE RESPIRATOR OR HOOD.
Ventilation:PROV SUFFICIENT VENT TO KEEP VAP CONC BELOW GIVEN TLV &
Other Protective Equipment:EYE BATH AND SHOWER SHOULD BE AVAILABE, USE
CHEM RESISTANT APRON, BOOTS OR CLOTHING. TO AVOID RPTD/FREQ SKIN
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
WASHROOM.
Supplemental Safety and Health
EFTS OF OVEREXP: HALOS AROUND LIGHTS. DRY PIGMENT MAY CAUSE A NUISANCE
DUST, WHICH CAN BE IRRT TO RESP SYSTEM . PRLNGD/RPTD SKIN CONT MAY
CAUSE DERMAT. MODERATELY TOX IF INGESTED. MAY CAUSE HDCHE, NAU S,
VOM, & WEAKNESS. PENETRATES SKIN READILY. FREQNT/ WIDESPREAD CNT
MAY RESULT IN ABSORP OF POTENTIALLY HARMFUL (ING 8)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:VENT: HEATING. REMOVE DECOMP PRODUCTS FORMED DURING
WELDING/FLAME CUTTING OF SURF COATED W/THIS PRODUCT.
Ingred Name:OTHER PROT EQUIP: CONTACT. LIQUID PENETRATE SHOES & LEATHER
CAUSING DELAYED IRRITATION.
Ingred Name:2-ETHOXYETHYL ACETATE (CELLOSOLVE ACETATE) (EGEEA)
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
Ingred Name:TOLUENE (SARA III)
Ingred Name:TALC (CONTAINING NO ASBESTOS)
OSHA PEL:2 MG/M3 RDUST
Ingred Name:N-BUTYL ACETATE (SARA III)
Ingred Name:2-BUTOXYETHANOL
Fraction by Wt: <5%
Ingred Name:CARBON BLACK
Fraction by Wt: <5%
OSHA PEL:3.5 MG/M3
Ingred Name:SUPP DATA: AMOUNTS WITH POSSIBLE INJURY TO KIDNEYS,LIVER,
BLOOD &/OR BONE MARROW. NOTICE: INTENTIONAL MISUSE (ING 9)
Ingred Name:ING 8: BY DELIBERATELY CONCENTRATING & INHAL CONTENTS MAYBE
Ingred Name:ING 9: EXPOSURE: TESTICULAR CHANGES, BLOOD CHANGES,
PRECAUTION, EXPOSURE TO LIQUIDS AND VAPORS OF PETROLEUM PRODS(ING
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE IRRIT. MAY CAUSE EYE BURNS/
CORNEAL INJURY.VAPS MAY BE IRRIT & CAUSE COUGHING, HDCH, NAUS, &
VOM. SKIN: MAY LEAD TO DEFATTING/MILD IRRIT. INGEST:MAY CAUSE HDCH,
NAUS, VOM, DIZZ, WEAKNESS. P OSS LIVER/KIDNEY DAMG MAY RESULT W/LGE
QTY OF MATL. INHAL: EXCESS INHAL OF VAP CAN CAUSE NASAL (EFTS OF
OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: & RESP IRRIT, DIZZ, WEAKNESS,
FATIGUE, NAUS, HDCH, POSSIBLE UNCONSC, AND ASPHYXIATION. INGEST:
MAY CAUSE GI IRRIT, NAUS, VOM, AND DIARRHEA. ASPIR OF MATL INTO
LUNGS CAN CAUSE CHEM PNEUMONITI S WHICH CAN BE FATAL. EYES: MAY
CAUSE SEVERE IRRIT, REDNESS, TEARING, BLURRED VISION, & SENSATION
OF SEEING (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE EXPECTED.
* First Aid Measures *
First Aid:INHAL: MOVE TO FRESH AIR. GIVE ARTIFICIAL RESPIRATION IF
NECESSARY. SKIN CONTACT: WASH WITH SOAP & WATER. EYE: FLUSH WITH
GLASSES OFWATER TO DILUTE, DO NOT INDUCE VOMITING. CONSULT
PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY, TREAT
SYMPTOMATICALLY.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1.1
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICALS.
CNTRS EXPOS TO FIRE. WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT
Unusual Fire/Explosion Hazard:KEEP CNTRS CLOSED, ISOLATE FROM HEAT,
ELEC EQUIP, SPARKS & OPEN FLAME. CLOSED CNTRS MAY EXPLODE WHEN
EXPOS TO EXTREME HEAT. APPLICN TO HOT SURF REQ SPEC PREC.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION, AVOID
BREATHING VAPORS, VENTILATE AREA, REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS,AND OPEN
FLAMES. CLOSE CNTRS AFTER EACH USE. CONSULT NFPA CODE FOR
ADDITIONAL STORAGE REQUIREMENTS.
Other Precautions:DO NOT TAKE INTERNALLY. USE APPROVED BONDING AND
GROUNDING PROCEDURES, OBSERVE LABEL PRECAUTIONS.
* Physical/Chemical Properties *
HCC:F3
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
SMOKE, OXIDES OF NITROGEN.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS. DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE, AND LOCAL POLLUTION CONTROL REQUIREMENTS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:DURING SPRAY APPLICATION USE NIOSH/MSHA APPROVED
MECHANICAL FILTER RESPIRATOR TO REMOVE SOLID AIRBORNE PARTICLES OF
OVERSPRAY.
Ventilation:PROVIDE SUFFICIENT VENT, IN VOL & PATTERN, TO INSURE VAP
CONC WELL BELOW ANY TLV & LEL LISTED IN INGRED & (ING 2)
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:OBSERVE GOOD SANITARY PRACTICES.
Supplemental Safety and Health
BASE W). OTHER PREC:HAZ ARE NOT BELIEVED TO BE PRESENT WHEN PWDRS
ARE DISPERSED IN LIQ COATINGS. HOWEVER, PRECS IN PROT SECT SHOU LD
BE CAREFULLY OBSERVED & RESPS SHOULDALSO BE USED IF DRIED COATING
IS SANDED/ABRADED IN SUCH A WAY AS TO PRDCE DUST.
* Product Identification *
Product ID:CHARLESTON'S FINEST WILLIAM M. BIRD (SUPP D
CAGE:0ANY1
CAGE:0ANY1
* Composition/Information on Ingredients *
Ingred Name:ETHYLENE GLYCOL (SARA III). VP:0.1
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:VENT:FIRE & EXPLOSION SECTION.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL:WITH POOR VENTILATION,
VAPOR OR SPRAY MIST MAY IRRITATE RESPIRATORY MUCOUS MEMBRANES,
CAUSING HEADACHE & NAUSEA. EYE:PRIMARY IRRITANT. CHRONIC: NONE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR. EYE:FLUSH IMMEDIATELY W/LARGE
TREATMENT. SKIN:REMOVE W/SOAP & WATER. IF DRENCHED, REMOVE
CONTAMINATED CLOTHING. INGEST:IF VICTIM IS CONSCIOUS, GIVE 2
GLASSES OF WATER TO DILUTE. DO NOT INDUCE VOMITING. CONSULT MD OR
POISON CONTROL CENTER.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:WATER FOG. (APPLICABLE ONLY FOR COOLING CLOSED
CONTAINER)
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT.
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AS DESCRIBED IN VENTILATION SECTION.
AVOID UNNECESSARY SKIN CONTACT. COLLECT BY ABSORPTION, SHOVEL &/OR
WET MOPPING.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
CONTAINER AFTER EACH USE. DO NOT TAKE INTERNALLY. OBSERVE GOOD
SANITARY PRACTICES.
Other Precautions:PIGMENTED PAINTS/COATINGS (THOSE WHICH ARE
OPAQUE/COLORED/WHICH HAVE REDUCED GLOSS WHEN DRY) MAY CONTAIN MATLS
SUCH AS SILICA, TALC, CALCIUM CARBONATE, TITANIUM DIOXIDE, ETC.
WHICH ARE HAZ TO INHALE I N DRY POWDER FORM. THESE (SUPP DATA)
* Physical/Chemical Properties *
HCC:N1
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:WHEN HEATED TO DECOMP, AS IN A FIRE OR
IN WELDING, MAY PRODUCE TOXIC FUMES SUCH AS CARBON MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE W/LOCAL, STATE & FEDERAL
REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:LOCAL EHXAUST AND MECHANICAL VENTILATION RECOMMENDED.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
CAGE:FERRC
CAGE:0NZB1
CAGE:FERRC
* Composition/Information on Ingredients *
Ingred Name:BISMUTH OXIDE; (BISMUTH TRIOXIDE)
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: MAY CAUSE COUGHING,
SHORTNESS OF BREATH. SKIN: MAY CAUSE ABRASION. EYES: DUST MAY
IRRITATE. CHRONIC: INHALATION: MAY AFFECT BREATHING CAPACITY.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. APPLY ARTIFICIAL RESPIRATION
AS NEEDED, OBTAIN FIRST AID OR MEDICAL ASSISTANCE. SKIN: OBTAIN
FIRST AID OR MEDICAL ASSISTANCE IF NEEDED. EYES: WASH WITH LARGE
MEDICAL ASSISTANCE IF NEEDED. INGESTION: OBTAIN FIRST AID OR
MEDICAL ASSISTANCE IF NEEDED.
* Fire Fighting Measures *
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:
* Accidental Release Measures *
Spill Release Procedures:HANDLE WITH ADEQUATE VENTILATION FOR NUISANCE
CONTAMINANTS). NORMAL CLEAN-UP PROCEDURES. NIOSH/MSHA APPROVED
RESPIRATORS IF NEEDED.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:USE W/COMMONLY ACCEPTED INDUSTRIAL
SAFETY PROCEDURES. AVOID INGESTION, INHALATION OF DUST/MIST,
EXPOSURE TO EYES/PROLONGED CONTACT W/SKIN.
Other Precautions:
* Physical/Chemical Properties *
Spec Gravity:8.5 (H*2O=1)
Appearance and Odor:ODORLESS YELLOW POWDER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HIGH DUSTING.
Hazardous Decomposition Products:
* Disposal Considerations *
Waste Disposal Methods:STANDARD LANDFILL METHODS, CONSISTENT WITH
APPLICABLE FEDERAL, STATE AND LOCAL LAWS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHERE TLVS ARE EXCEEDED, USE NIOSH/MSHA APPROVED
RESPIRATORY PROTECTION. IN CONFINED AREAS, USE NIOSH/MSHA APPROVED
AIR SUPPLIED RESPIRATORS.
Ventilation:GENERAL DILUTION OR LOCAL EXHAUST IN VOLUME/PATTERN TO KEEP
BELOW TLV
Other Protective Equipment:SAFETY SHOWER, EYE BATH & WASHING FACILITIES
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
DON'T DELIBERATELY CONCENTRATE THIS PRODUCT & INHALE VAPORS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:2-HEPTANONE, METHYL N-AMYL KETONE
Ingred Name:1,3-BENZENEDICARBOXYLIC ACID POLYMER (POLYESTER RESIN)
Ingred Name:TOLUENE
Fraction by Wt: <1%
Ingred Name:BIS (1,2,2,6,6-PENTAMETHYL-4-PIPERIDINYL) SEPACATE
Fraction by Wt: <5%
Ingred Name:TITANIUM DIOXIDE, TIO2
Ingred Name:ADDITIVES (TRADE SECRET)
Ingred Name:RESIN (TRADE SECRET)
Ingred Name:PIGMENTS (TRADE SECRET)
Ingred Name:METHYL PROPYL KETONE
Fraction by Wt: 5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NASAL & RESPIRATORY
IRRITATION, CENTRAL NERVOUS SYSTEM DEPRESSION; ASPHYXIATION MAY
RESULT FROM OXYGEN DEFICIENT AIR. SKIN: IRRITATION, DERMATITIS;
SENSITIZATION. EYES: IRRITATION. INGESTI ON: GASTROINTESTINAL
IRRITATION. PROLONGED OVEREXPOSURE TO SOLVENTS: PERMANENT BRAIN &
NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: HEADACHE, DIZZINESS, STAGGERING
GAIT, CONFUSION, UNCONSCIOUSNESS, CONCENTRATION DIFFICULTIES,
DIMINISHED ACTUAL DEXTERITY, MEMORY LOSS.
Medical Cond Aggravated by Exposure:SKIN, LUNG & EYE CONDITIONS
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN AS REQUIRED.
KEEP WARM & QUIET. SKIN: WASH W/SOAP & WATER. DON'T USE SOLVENTS.
INGESTION : OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:SCC
Lower Limits:1%
Extinguishing Media:CO2, DRY CHEMICAL OR FOAM
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. COOL FIRE
EXPOSED CONTAINER W/WATER. FOG NOZZLES ARE PREFERRABLE & PROTECTIVE
CLOTHING.
Unusual Fire/Explosion Hazard:VAPORS MAY ACCUMULATE, TRAVEL LONG
DISTANCES & FLASHBACK AT HANDLING SITE. VAPORS MAY FORM EXPLOSIVE
MIXTURES W/AIR. CLOSED CONTAINERS MAY EXPLODE. FLAMMABLE.
* Accidental Release Measures *
Spill Release Procedures:REMOVE IGNITION SOURCES. WEAR PERSONAL
PROTECTIVE EQUIPMENT. AVOID BREATHING VAPORS; SKIN/EYE CONTACT. USE
NON-SPARKING TOOLS. SMALL: DIKE & ABSORB W/INERT MATERIAL. LARGE:
USE EMERGENCY RESPONSE PROF ESSIONAL IF BEYOND CAPABILITY OF
IN-HOUSE PERSONS.
*Handling and Storage *
CONTAINER TIGHTLY CLOSED. USE GROUNDING/BONDING PROCEDURES WHEN
TRANSFERRING MATERIAL. AVOID FREE FALL OF LIQUID.
Other Precautions:DON'T SMOKE IN AREAS WHERE USED/STORED. DON'T APPLY
TO HOT SURFACES. DON'T TAKE INTERNALLY. AVOID BREATHING VAPORS,
SKIN & EYE CONTACT. EMPTY DRUMS MAY CONTAIN EXPLOSIVE VAPORS. DON'T
CUT, PUNCTURE OR WELD ON OR NEAR DRUM. (SEE SUPPL.)
* Physical/Chemical Properties *
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN N-BU AC
Appearance and Odor:GRAY LIQUID W/SOLVENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:IGNITION SOURCES
Hazardous Decomposition Products:CO & CO2
* Disposal Considerations *
Waste Disposal Methods:ENSURE PRODUCT IS
PACKAGED/STORED/TRANSPORTED/DISPOSED/MANAGED IN ACCORDANCE
W/FEDERAL, STATE & LOCAL REGULATIONS. NO DISPOSAL METHOD IS TO BE
USED THAT WOULD POSE AN ENVIRONMENTAL/HUMAN HEALTH THREAT
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:RESPIRATORY PROT REQUIRED IF AIRBORNE
NIOSH/MSHA APPRVD CHEMICAL CARTRIDGE RESPIRATOR W/ACID/ORGANIC
CARTRIDGE IS RECOM. ABOVE THIS LEVEL, A NIOSH/MSHA APPRVD SCBA IS
ADVISED.
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO MEET TLV
REQUIREMENTS.
Other Protective Equipment:UNIFORM, PROTECTIVE SUIT, LAB COAT, APRON,
VENT HOOD & CLASS B EXTINGUISHER. EMERGENCY EYEWASH & DELUGE SHOWER
.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
PH:2.4 (1.0M SOLUTION). FIRE FIGHT PROC: EXPOSED CONTRS COOL. EXPLO
HAZ:REACTS W/MOST METALS TO PRDCE HYDROGEN GAS, WHICH CAN FORM AN
EXPLOS MIX W/AIR. MATLS TO AVOID:PEROXIDE, ALKALIES, CARBONATES, S
TRONG BASES, AMINES, PHOSPHORUS TRICHLORIDE & PHOSPHORUS
PENTACHLORIDE. SPILL PROC:FROM SPILL AREA. FLUSH AREA (ING 2)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ACETIC ACID (SARA III); (ACETIC ACID, GLACIAL)
Ingred Name:SUPP DATA:WITH WATER. DO NOT ALLOW TO ENTER DRAIN OR SEWER
SYSTEM.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:RESP SYS, EYES, SKIN,
TEETH & LUNGS. ACUTE:INHAL:SEV IRRIT/BURNS OF RESP SYS, PULM EDEMA,
LUNG INFLAMM, HDCH, COUGHING, DFCLT BRTHG, DIZZ, CHEST PAINS, TEETH
DAM & RESP FAILURE. SKIN:SEV BURNS. MAY CAUSE DERM. EYE:SEV BURNS
&PERM EYE DAMAGE. INGEST: BURNS TO MOUTH & THROAT, NAUS, VOM, (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:GASTROINTESTINAL IRRITATION, DIARRHEA,
SHOCK & MAY BE FATAL. CHRONIC:LUNG DAMAGE & TEETH DAMAGE.
Medical Cond Aggravated by Exposure:RESPIRATORY SYSTEM DISEASE & SKIN
DISORDERS.
* First Aid Measures *
First Aid:INGEST:CALL MD. DO NOT INDUCE VOMITING. IF CONSCIOUS, GIVE
WATER, MILK OR MILK OF MAGNESIA. INHAL:REMOVE TO FRESH AIR. IF NOT
BRTHG, GIVE ARTF RESP. IF BRTHG IS DIFFICULT, GIVE OXYGEN. SKIN:
CONTAMD CLTHG & SHOES. WASH CLTHG BEFORE REUSE. EYES:IMMED FLUSH
* Fire Fighting Measures *
Flash Point Method:CC
Upper Limits:4.0%
Extinguishing Media:USE WATER SPRAY, ALCOHOL FOAM, DRY CHEMICAL OR
CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE CLOTHING . MOVE CONTRS FROM FIRE AREA IF IT CAN BE DONE
W/ OUT RISK. USE WATER TO KEEP FIRE (SUPP DATA)
Unusual Fire/Explosion Hazard:VAPS MAY FLOW ALONG SURF TO DISTANT IGNIT
SOURCES & FLASH BACK. CLSD CONTRS EXPOSED TO HEAT MAY EXPLODE. CONT
W/ STRONG OXIDIZERS MAY CAUSE FIRE. (SUPP DATA)
* Accidental Release Measures *
Spill Release Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT CLTHG.
SHUT OFF IGNIT SOURCES; NO FLARES/SMKNG/FLAMES IN AREA. STOP LEAK
IF YOU CAN W/OUT RISK. NEUT SPILL W/SODA ASH/LIME. W/CLEAN SHOVEL,
CAREFULLY PLACE MATL INTO CLEAN, DRY CONTR & COVER. REMOVE (SUPP
DATA)
Neutralizing Agent:J T BAKER NEUTRASORB(R) OR TEAM(R) 'LOW NA+' ACID
NEUTS ARE RECOM FOR SPILLS.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL-VENTD,
KEEP AWAY FROM HEAT/ SPARKS/FLAME. USE W/ADEQ VENT.
Other Precautions:DANGER. COMBUSTIBLE. CAUSES SEVERE BURNS. HARMFUL IF
SWALLOWED OR INHALED. DO NOT GET IN EYES, ON SKIN OR ON CLTHG.
AVOID BREATHING VAPOR. KEEP OUT OF REACH OF CHILDREN.
* Physical/Chemical Properties *
HCC:F6
Vapor Density:2.1
pH:SUPDAT
Appearance and Odor:COLORLESS LIQUID; VINEGAR LIKE ODOR.
* Stability and Reactivity Data *
STRONG OXIDIZING AGENTS, MOST COMMON METALS (EXCEPT ALUM), CHROMIC,
NITRIC & SULFURIC ACIDS, HYDROGEN (SUPP DATA)
Stability Condition to Avoid:HEAT, FLAMES & OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:CO & CO2.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE W/ALL APPLICABLE FEDERAL,
STATE & LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | eyes_protection_mandatory |
Control Measures
*
Proprietary Ind: Y
*
Preparer Co. when other than Responsible Party Co.
*
*
Contractor Summary
*
*
Item Description Information
*
Item Manager: GSA
Item Name: ADHESIVE
Unit of Issue: KT
UI Container Qty: 0
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: CORROSIVE TO EYES & SKIN. MAY CAUSE SKIN/EYE
IRRITATION. BRIEF CONTACT MAY CAUSE CHEMICAL BURNS. VAPORS & MISTS WILL
IRRITATE NOSE & THROAT. REPEATED/PROLONGED SKIN CONTACT MAY RESULT IN
BURNS & POSSI BLE ALLERGIC SENSITIZATION.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: IRRITATION, BURNS & CHEST DISCOMFORT.
Medical Cond Aggravated By Exposure: SKIN SENSITIZATION.
THOROUGHLY W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION:
DRINK PLENTY OF WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
*
Handling and Disposal
*
GLASSES. ABSORB W/ABSORBENT MATERIAL. SCRAPE UP/SHOVEL INTO DOT APPROVED
WASTE CONTAINERS.
Waste Disposal Methods: INCINERATION IN AN EPA-APPROVED WASTE INCINCERATOR IS A
PREFERRED DISPOSAL PRACTICE. DISPOSE OF IAW/FEDERAL, STATE & LOCAL
RETAIN PRODUCT RESIDUE.
Other Precautions: FAILURE TO OBSERVE CAUTION MAY RESULT IN EXCESSIVE HEAT
BUILD-UP WHICH MAY CAUSE AN EXOTHERM. EXOTHERM HAS POTENTIAL FOR RELEASE OF
TOXIC GASES. DON'T CUT, GRIND, WELD/DRILL ON/NEAR THIS CONTAINER.
*
Fire and Explosion Hazard Information
*
Extinguishing Media: DRY CHEMICAL, HALON FIRE EXTINGUISHER, WATER SPRAY, FOAM,
FOG.
Fire Fighting Procedures: WEAR A SELF-CONTAINED BREATHING APPARATUS & FULL
PROTECTIVE CLOTHING/TURN-OUT GEAR. CARTRIDGE RESPIRATORS DON'T PROVIDE
ADEQUATE PROTECTION/EXOTHERM MITIGATION.
Unusual Fire/Explosion Hazard: MAY LIBERATE LARGE QUANTITIES OF DENSE
FOUL-SMELLING SMOKE WHICH MAY CONTAIN UNIDENTIFIED TOXIC GASES.
*
*
Respiratory Protection: WEAR A RESPIRATOR EQUIPPED W/ORGANIC VAPOR CARTRIDGES
IF LOCAL EXHAUST VENTILATION IS INADEQUATE.
Ventilation: LOCAL EXHAUST AT POINT OF USE.
EYEWASH & SAFETY SHOWER
Supplemental Safety and Health: DON'T HEAT MIXED ADHESIVE UNLESS CURING
SURFACES TO BE BONDED.
*
Physical/Chemical Properties
*
Appearance and Odor: BLUE LIQUID W/AMMONIACAL ODOR.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: MIXING RESIN & CURING AGENT IN BATCHES >1 LB
UNLESS PLANNING TO USE IMMEDIATELY. (SEE SUPP)
Materials To Avoid: STRONG OXIDIZING AGENTS, STRONG LEWIS/MINERAL ACIDS.
Hazardous Decomposition Products: CO, NITROGEN OXIDES, ALDEHYDES, ACIDS &
UNDERTERMINED ORGANICS.
Hazardous Polymerization Indicator: YES
Conditions To Avoid Polymerization: MIXING RESIN & CURING AGENT IN BATCHES >1
LB UNLESS PLANNING TO USE IMMEDIATELY. (SEE SUPP).
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Company Name: DEXTER CORPORATION ADHESIVE & COATING SYSTEMS
Label Required IND: Y
Status Code: C
Origination Code: G
Hazard And Precautions: CORROSIVE TO EYES & SKIN. MAY CAUSE SKIN/EYE
IRRITATION. BRIEF CONTACT MAY CAUSE CHEMICAL BURNS. VAPORS & MISTS WILL
IRRITATE NOSE & THROAT. REPEATED/PROLONGED SKIN CONTACT MAY RESULT IN
BURNS & POSSI BLE ALLERGIC SENSITIZATION.
IRRITATION, BURNS & CHEST
DISCOMFORT.
*
| 1 | eyes_protection_mandatory |
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.