text
stringlengths 307
13.1k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATORY APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST:RECOMMENDED.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:SHOULD BE WELL VENTILATED AREA WHEN DETONATED.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:HEXANITROSTILBENE; (HIGH SURFACE HEXANITROSTILBENE (HNS)
(EXPLOSIVES))
ACGIH TLV:N/K
Ingred Name:KEL-F BINDER (CONTAINING INGS 3 & 4)
Fraction by Wt: 2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHENE, CHLOROTRIFLUORO-, HOMOPOLYMER;
(CHLOROTRIFLUOROETHYLENE COPLYMER)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHYLENE, 1,1-DIFLUORO-; (VINYLIDENE FLOURIDE COPOLYMER)
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:OVEREXPOSURE TO FUMES AFTER
DETONATION MAY CAUSE NAUSEA. CHRONIC:NONE LISTED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:INGEST:CALL MD IMMEDIATELY . EYES:IMMEDIATELY FLUSH EYES
SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD. . INHAL:RE MOVE
AFFECTED PERSON TO WELL VENTILATEDAREA AND CALL PHYSICIAN IF
NEEDED.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, FIRE EXTINGUISHER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . DO NOT ATTEMPT TO PUT OUT THE FIRE, BUT
IMMEDIATELY EVACUATE THE AREA.
Unusual Fire/Explosion Hazard:MAY DETONATE IF CONFINED.
* Accidental Release Measures *
Spill Release Procedures:DISPOSE OF POWDER AS EXPLOSIVE WASTE. USE
WATER IF NECESSARY. DO NOT USE ACETONE SINCE IT IS USED TO DISSOLVE
MOST TYPES OF POWDERS AND MAKES IT DIFFICULT TO CLEAN UP.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM HEAT & OPEN FLAME.
EXPLOSIVE STORAGE LIMITS OF DESIGNATED AREAS SHOULD BE FOLLOWED. DO
NOT IMPACT AND CRUSH SLEEVE.
Other Precautions:
* Physical/Chemical Properties *
Solubility in Water:0
Appearance and Odor:NO ODOR, YELLOW-BUFF POWDER IN DETONATOR HOUSING.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NOT APPLICABLE.
Stability Condition to Avoid:
Hazardous Decomposition Products:CHLORIDES, FLUORIDES AND PHOSGENE .
* Disposal Considerations *
Waste Disposal Methods:DETONATE IN SUITABLE CHAMBER. BURN IN UNCONFINED
CONTAINER. DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS .
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHERE ENVIRONMENTAL CONTROLS ARE LACKING OR IN
ENCLOSED SPACES USE A NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC
VAPORS.
Ventilation:LOCAL VENTILATION AT THE WORKSITE;MECHANICAL(GENERAL)
VENTILATION TO MAINTAIN TLV/PEL.
Other Protective Equipment:PROTECTIVE CLOTHING AS REQUIRED TO MINIMIZE
EXPOSURE FROM PROLONGED OR REPEATED CONTACT. EYE BATH AND SAFETY
SHOWER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE. DISCARD
CONTAMINATED SHOES
Supplemental Safety and Health
USED GASOLINE MOTOR OILS HAVE BEEN SHOWN TO CAUSE SKIN CANCER WHEN
REPEATEDLY APPLIED TO MOUSE SKIN WITHOUT ANY EFFORT TO REMOVE THE
MATERIAL BETWEEN APPLICATIONS. THERE IS NO EVIDENCE OF A CAUSAL REL
ATIONSHIP BETWEEN SKIN CANCER IN HUMANSAND EXPOSURE TO USED MOTOR
OIL.
* Product Identification *
CAGE:TEXLU
CAGE:TEXLU
* Composition/Information on Ingredients *
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATE, SOLVENT DEWAXED (MILD),
HEAVY PARAFFINIC
Other REC Limits:NONE RECOMMENDED
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES,HYDROTREATED
(MILD),HEAVY PARAFFINIC
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:MINERAL OIL
Fraction by Wt: 1-3%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:MAY CAUSE MINIMAL
IRRITATION.SKIN:MAY CAUSE SLIGHT IRRITATION.INGEST:SWALLOWING MORE
THAN SEVERAL MOUTHFULS MAY CAUSE GI TRACT IRRITATION.INHAL:VAPORS
IN CONFINED SPACES MAY CAUSE RESPIRATORY IRR ITATION.EXPOSURE TO
H*2S MAY CAUSE RESPIRATORY PARALYSIS.
Explanation of Carcinogenicity:USED GASOLINE MOTOR OIL IS A POSSIBLE
SKIN CANCER HAZARD.
Effects of
Overexposure:INGEST:NAUSEA,DIARRHEA.SKIN:REDNESS,SWELLING.INHAL:HEA
DACHE,NAUSEA,DROWSINESS.H*2S EXPOSURE ABOVE
Medical Cond Aggravated by Exposure:BECAUSE OF ITS DEFATTING
PROPERTIES, PROLONGED AND REPEATED SKIN CONTACT MAY AGGRAVATE AN
EXISTING DERMATITIS.
* First Aid Measures *
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH SOAP AND
WATER.GET MEDICAL ATTENTION IF IRRITATION PERSISTS.EYES:FLUSH WITH
PERSISTS.INHAL:REMOVE T O FRESH AIR.GIVE OXYGEN OR ARTIFICIAL
RESPIRATION IF NEEDED.INGEST:DO NOT INDUCE VOMITING.GET PROMPT
WATER.
* Fire Fighting Measures *
Flash Point Method:COC
Extinguishing Media:USE WATER SPRAY, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL. WATER OR FOAM MAY CAUSE FROTHING.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
* Accidental Release Measures *
Spill Release Procedures:REMOVE PERSONNEL. VENTILATE AREA. WEAR
PROTECTIVE CLOTHING AND EQUIPMENT. DIKE AND CONTAIN. ABSORB IN
INERT MATERIAL AND PLACE IN APPROPIATE DISPOSAL CONTAINER AND
COVER. WASH AREA WITH SOAP AND WATER .AVOID ENTRY INTO SEWERS.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP AWAY FROM HEAT, OPEN FLAMES AND STRONG
OXIDANTS. KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:HYDROGEN SULFIDE MAY ACCUMULATE IN CONTAINER
HEADSPACE.AVOID EYE AND SKIN CONTACT. DO NOT BREATHE VAPORS.SOILED
LAUNDRY SHOULD BE DRY-CLEANED.AVOID WATER CONTAMINATION.
* Physical/Chemical Properties *
HCC:V6
Vapor Pres:NEGLIGIBLE
Appearance and Odor:BRIGHT CLEAR LIQUID.ODOR NOT DETERMINED.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:H*2S(IF OVERHEATED).
* Disposal Considerations *
Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:THIS CHEMICAL SHOULD BE HANDLED ONLY IN HOOD.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: IF PATIENT HAS STOPPED BRTHG ADMIN ARTF RESP. IF
PATIENT IS IN CARDIAC ARREST ADMIN CPR. IF PATIENT IS IN CARDIAC
ARREST ADMIN CPR. CONTINUE LIFE SUPPORTING MEASURES UNTIL MEDICAL
ASSI STANCE HAS ARRIVED.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ETHANE, 1,2-BIS(2-CHLOROETHOXY)-;
(1,2-BIS(2-CHLOROETHOXY)ETHANE)
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT LENSES SHOULD NOT BE WORN IN
LAB. ALL CHEMICALS SHOULD BE CONSIDERED HAZARDOUS - AVOID DIRECT
PHYSICAL CONTACT! CAN BE HARMFUL IF INGESTED. CAN BE HARMFUL IF
INHALED. CAN BE HARMFUL IF ABSORBE D THROUGH SKIN. CAN CAUSE EYE &
SKIN IRRIT. DUST &/VAPORS CAN CAUSE IRRIT TO RESP TRACT. CAN BE
IRRIT(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: TO MUCOUS MEMBRANES.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:ANTIDOTE IS A SUBSTANCE INTENDED TO COUNTERACT EFT OF POIS.
IT SHOULD BE ADMIN ONLY BY MD/TRAINED EMER PERS. MED ADVICE CAN BE
OBTAINED FROM POIS CTRL CTR. EYE: FLUSH CONTINUOUSLY W/WATER FOR AT
HAVE OCCURRED-USE SOAP & WATER TO CLEANSE SKIN. INHAL: REMOVE
PATIENT TO FRESH AIR. ADMIN O*2 IF PATIENT IS HAVING DFCLTY
BRTHG.(SUPDAT)
* Fire Fighting Measures *
Extinguishing Media:USE EXTINGUISHING MEDIA SUITABLE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:PEROXIDE FORMER - DISCARD OUT OF DATE
MATERIAL.
* Accidental Release Measures *
Spill Release Procedures:EVAC AREA. WEAR APPROP OSHA/NIOSH/MSHA APPRVD
EQUIP. VENT AREA. ABSORB ON VERMICULITE OR SIMILAR MATL. SWEEP UP &
PLACE IN AN APPROP CNTNR. HOLD FOR DISP. WASH CONTAMD SURFACES TO
REMOVE ANY RESIDUES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE UNDER NITROGEN. KEEP TIGHTLY
CLSD & STORE IN COOL DRY PLACE. STORE ONLY W/COMPATIBLE CHEMICALS.
AVOID CONTACT W/SKIN, EYES & CLTHG.
Other Precautions:THIS PRODUCT IS FURNISHED FOR LAB USE ONLY! PRODUCTS
MAY NOT BE USED AS DRUGS, COSMETICS, AGRICULTURAL OR PESTICIDAL
PRODUCTS, FOOD ADDITIVES OR AS HOUSEHOLD CHEMICALS.
* Physical/Chemical Properties *
Appearance and Odor:COLORLESS LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS, STRONG BASES.
Stability Condition to Avoid:FLAMM. EASILY OXIDIZED-MAY BE PEROXIDE
FORMER-CHECK FOR PEROXIDES ON ALL OPENED SAMPLES.
Hazardous Decomposition Products:DECOMPOSITION LIBERATES TOXIC FUMES.
* Disposal Considerations *
Waste Disposal Methods:BURN IN CHEMICAL INCINERATOR EQUIPPED W/AN AFTER
BURNER & SCRUBBER. DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE SELF-CONTAINED BREATHING APPARATUS OR
AIRLINE RESPIRATORS WHEN CARBON DIOXIDE HAS BEEN RELEASED AND HAS
Ventilation:MECHANICAL (GENERAL) AND/OR LOCAL EXHAUST VENTILATION TO
KEEP EXPOSURE LEVELS BELOW PEL.
Other Protective Equipment:NONE REQUIRED
Work Hygienic Practices:USE GOOD PERSONAL HYGIENE AND GOOD HOUSEKEEPING
PRACTICES.
Supplemental Safety and Health
NONE.
* Product Identification *
Product ID:CARBON DIOXIDE
Preparer's Name:D.EMERICH OR D.ELLISON
* Composition/Information on Ingredients *
Ingred Name:CARBON DIOXIDE
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: CONTACT WITH LIQUID OR SOLID
WILL CAUSE BURNS, FROSTBITE, OR BLINDNESS. SKIN: CONTACT WITH
LIQUID OR SOLID WILL CAUSE BURNS OR FROSTBITE. INHALATION: SLIGHTLY
TOXIC ASPHYXLANT. INGESTION: NOT LI KELY.
Explanation of Carcinogenicity:NONE OF THE INGREDIENTS IN THIS PRODUCT
IS LISTED BY NTP, IARC OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EFFECTS OF CHRONIC OVEREXPOSURE FOR PRODUCT:
HIGH CONCENTRATIONS CAN PARALYZE RESPIRATORY CENTER. INCREASED
INHALATION WILL CAUSE INCREASED BREATHING RATE. UNCONSCIOUSNESS AND
DEATH MAY RESULT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:EYES: TREAT AREAS EXPOSED TO SOLID OR LIQUID AS FROSTBITE.
SEEK MEDICAL ATTENTION. SKIN: TREAT AREAS EXPOSED TO SOLID OR
LIQUID AS FROSTBITE. SEEK MEDICAL ATTENTION. INHALATION: PROVIDE
FRESH AIR OR O XYGEN. IF SYMPTOMS PERSISTS, SEEK MEDICAL ATTENTION.
INGESTION: TREAT AREAS EXPOSED TO SOLID OR LIQUID AS FROSTBITE.
SEEK MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:THIS MATERIAL IS AN EXTINGUISHING AGENT.
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:LEAKS WILL DISSIPATE RAPIDLY AND HARMLESSLY TO
ATMOSPHERE. FOR CONFINED AREAS REMOVE ALL PERSONNEL AND VENTILATE
AREA. VENT TO ATMOSPHERE IN OPEN AREA.
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM DIRECT HEAT OR OPEN
FLAME.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:G3
Appearance and Odor:COLORLESS LIQUID OR GAS. NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CHEMICALLY ACTIVE METALS, SUCH AS SODIUM, POTASSIUM, HOT TITANIUM.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:NONE SPECIFIED BY MANUFACTURER.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT ORDINARILY REQUIRED.
Ventilation:NOT PROVIDED.
Other Protective Equipment:USE OIL RESISTANT CLOTHING AS NEEDED TO
MINIMIZE SKIN CONTACT.
Work Hygienic Practices:NOT PROVIDED.
Supplemental Safety and Health
INDUCTION IS UNNECESSARY IN HIGH VISCOSITY, LOW VOLATILITY PROD
UCTS, I.E., MOST OILS AND GREASES.
* Product Identification *
Preparer's Name:KAREN G. HAYNES
* Composition/Information on Ingredients *
Ingred Name:POLYALPHAOLEFINS
Other REC Limits:NOT PROVIDED.
Ingred Name:INORGANIC CLAY
= Wt:6.
Other REC Limits:NOT PROVIDED.
Ingred Name:FATTY ACID AMIDES
= Wt:4.
Other REC Limits:NOT PROVIDED.
Ingred Name:OTHER COMPONENTS
= Wt:4.
Other REC Limits:NOT PROVIDED.
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT: MAY BE MILDLY IRRITATING
TO THE EYES. SKIN CONTACT: PROLONGED OR REPEATED CONTACT MAY CAUSE
VARIOUS SKIN DISORDERS SUCH AS DERMATITIS, FOLLICULITIS OR OIL
ACNE. RELEASE DURING HIGH PRESSU RE USAGE MAY RESULT IN INJECTION
OF GREASE INTO THE SKIN CAUSING LOCAL NECROSIS. INHALATION: NO
SPECIFIC INFORMATION IDENTIFIED. INGESTION: NO SPECIFIC INFORMATION
IDENTIFIED. THIS SPECIFIC PRODUCT HA S NOT BEEN TESTED IN
LONG-TERM, CHRONIC EXPOSURE TEST. LUBRICATING GREASES ARE GENERALLY
CONSIDERED TO BE OF A LOW ORDER OF ACUTE TOXICITY TO HUMANS AND
EXPERIMENTAL ANIMALS.
Explanation of Carcinogenicity:THIS PRODUCT AND ITS COMPONENTS ARE NOT
CLASSIFIED AS CARCINOGENS BY INTERNATIONAL AGENCY FOR RESEARCH ON
CANCER (IARC), NATIONAL TOXICOLOGY PROGRAM (NTP) OR OCCUPATIONAL
SAFETY AND HEALTH ADMINISTRAT ION (OSHA).
Effects of Overexposure:IRRITATION AS NOTED ABOVE. LOCAL NECROSIS IS
EVIDENCED BY DELAYED ONSET OF PAIN AND TISSUE DAMGE A FEW HOURS
FOLLOWING INJECTION.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS MAY BE
AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
* First Aid Measures *
EYELIDS OPEN. GET MEDICAL ATTENTION. SKIN CONTACT: REMOVE
CONTAMINATED CLOTHING AND WIPE EXCESS OFF. WASH WITH SOAP AND
WATER. IF IRRITATION PERSISTS, GET MEDICAL ATTENTION. IF MATERIAL
IS INJECTED UNDER THE SKIN, GET MEDICAL ATTENTION PROMPTLY TO
PREVENT SERIOUS DAMAGE; DO NOT WAIT FOR SYMPTOMS TO DEVELOP.
INHALATION: REMOVE VICTIM TO FRE SH AIR AND PROVIDE OXYGEN IF
BREATHING IS DIFFICULT. GET MEDICAL ATTENTION. INGESTION: DO NOT
INDUCE VOMITING. IN GENERAL, NO TREATMENT IS NECESSARY UNLESS LARGE
QUANTITIES ARE INGESTED. HOWEVER, GET MEDICAL ADVICE.
* Fire Fighting Measures *
Flash Point Method:PMCC
SYNTH HYDRO.
Lower Limits:N/AV
Upper Limits:N/AV
Extinguishing Media:USE WATER FOG, DRY CHEMICAL OR CO2. DO NOT USE A
DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE REIGNITED ON
SURFACE OF WATER.
Fire Fighting Procedures:DO NOT ENTER CONFINED FIRE SPACE WITHOUT
PROPER PROTECTIVE EQUIMENT INCLUDING A NIOSH APPROVED
SELF-CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED CONTAINERS
SURROUNDING EQUIPMENT AND STTRUCTURES WI TH WATER.
Unusual Fire/Explosion Hazard:NONE IDENTIFIED.
* Accidental Release Measures *
Spill Release Procedures:SCOOP UP EXCESS GREASE. CLEAN AREA WITH
APPROPRIATE CLEANER.
Neutralizing Agent:NOT RELEVANT.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP AWAY FROM OPEN FLAMES AND HIGH
TEMPERATURES.
Other Precautions:MINIMIZE SKIN CONTACT. WASH WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING, OR USING TOILET FACILITIES.
LAUNDER CONTAMINATED CLOTHING BEFORE REUSE. PROPERLY DISPOSE OF
CONTAMINATED LEATHER ARTIC LES INCLUDING SHOES THAT CANNOT BE
DECONTAMINATED.
* Physical/Chemical Properties *
HCC:V6
NRC/State Lic Num:NOT RELEVANT.
Boiling Pt:B.P. Text:NOT AVAILABLE
Melt/Freeze Pt:M.P/F.P Text:NOT AVAILABLE
Decomp Temp:Decomp Text:NOT PROVIDED.
Vapor Pres:NOT AVAILABLE
Spec Gravity:NOT AVAILABLE
pH:NOT RELEVANT.
Viscosity:NOT RELEVANT.
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER, SMOOTH, SLIGHT ODOR.
Percent Volatiles by Volume:NOT PROVIDED
Corrosion Rate:NOT PROVIDED.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID HEAT, OPEN FLAME.
Hazardous Decomposition Products:A COMPLEX MIXTURE OF AIRBORNE SOLID,
LIQUID PARTICULATES AND GASES EVOLVE WHEN MATERIAL UNDERGOES
PYROLYSIS/COMBUSTION. CARBON MONOXIDE AND UNIDENTIFIED ORGANIC
COMPOUNDS MAY BE FORMED UPON COMBUSTION.
* Toxicological Information*
Toxicological Information:NO OSHA/PEL OR ACGIH/TLV HAS BEEN
* Ecological Information *
Ecological:NOT PROVIDED.
* Disposal Considerations *
Waste Disposal Methods:IF THIS PRODUCT BECOMES A WASTE, IT WOULD NOT BE
APPROPRIATE DISPOSAL FACILITY IN COMPLICANCE WITH LOCAL
REGULATIONS..
* MSDS Transport Information *
Transport Information:DEPARTMENT OF TRANSPORTATION CLASSIFICATION: NOT
HAZARDOUS BY D.0.T. REGULATIONS. DOT PROPER SHIPPING NAME: NOT
APPLICABLE. OTHER REQUIREMENTS: NOT APPLICABLE.
* Regulatory Information *
SARA Title III Information:BASED ON THE DATA AVAILABLE THIS PRODUCT IS
NOT REGULATED BY SARA, TITLE III. THIS PRODUCT IS COVERED BY EPA'S
COMPREHENSIVE ENVIRONMENTAL RESPONSE, COMPENSATION AND LIABILITY
ACT (CERCLA) PETROLEUM E XCLUSION. THEREFORE, RELEASES TO AIR,
LAND, OR WATER ARE NOT REPORTABLE UNDER CERCLA ("SUPERFUND").
PRODUCT IS CONSIDERED AN OIL. AS SU CH, SPILLS INTO OR LEADING TO
SURFACE WATERS THAT CAUSE A SHEEN MUST BE REPORTED TO THE NATIONAL
Federal Regulatory Information:THE COMPONENTS OF THIS PRODUCT ARE
LISTED ON THE EPA/TSCA INVENTORY OF CHEMICAL SUBSTANCES. THIS
THIS RULE. PROTECTION OF STRATOSPHERIC OZONE (PURSUANT TO SECTION
THIS P RODUCT DOES NOT CONTAIN NOR WAS IT DIRECTLY MANUFACTURED
WITH ANY CLASS I OR CLASS II OZONE DEPLETING SUBSTANCES.
State Regulatory Information:BASED ON INFORMATION AVAILABLE, THIS
PRODUCT DOES NOT CONTAIN ANY CHEMICAL SUBSTANCE LISTED ON A
CHEMICAL SPECIFIC STATE LIST.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:MATERIAL SHOULD BE HANDLED/TRANSFERRED IN AN APPROVED FUME
HOOD OR W/ADEQUATE VENTILATION.
Other Protective Equipment:EMERG EYE WASH AND DELUGE SHOWER WHICH MEETS
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
SPILL PROC:UP & CONTAINERIZE FOR PROPER DISPOSAL AS DESCRIBED UNDER
DISPOSAL. COMPLY W/FEDERAL, STATE & LOCAL REGS ON REPORTING
RELEASES. REFER TO REGULATORY INFO FOR REPORTABLE QTY & OTHER
REGULATORYDATA.
* Product Identification *
* Composition/Information on Ingredients *
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:WILL STAIN SKIN DARK RED. APPARENT LOW
ORDER OF TOXICITY. MAY CAUSE ALLERGIC REACTION, SKIN IRRITATION ON
PROLONGED CONTACT & UPPER RESPIRATORY IRRITATION ON ACUTE
INHALATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:DATA NOT AVAILABLE.
* First Aid Measures *
First Aid:GET MEDICAL ASSISTANCE FOR ALL CASES OF OVEREXPOSURE.
SKIN:WASH THOROUGHLY W/SOAP & WATER. EYES:IMMEDIATELY FLUSH
AIR; GIVE ARTIFICIAL RESPIRATION IF BREATHING HAS STOPPED.
INGEST:GET IMMEDIATE MEDICAL ATTENTION; IF CONSCIOUS, GIVE WATER
FREELY.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, WATER, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE INDICATED.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE AREA OF ALL UNNEC PERS. WEAR SUITABLE
PROT EQUIP LISTED UNDER EXPOS/PERSONAL PROT. ELIM ANY IGNIT SOURCES
UNTIL AREA IS DETERMINED TO BE FREE FROM EXPLO/FIRE HAZS. CONTAIN
RELS & ELIM ITS SOU RCE, IF THIS CAN BE DONE W/OUT RISK. TAKE
(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED. STORE AT
CONTROLLED ROOM TEMPERATURE. DO NOT BREATHE DUST. DO NOT GET IN
EYES, ON SKIN, OR ON CLOTHING. DO NOT TAKE INTERNALLY.
Other Precautions:HANDLING CARE GENERALLY IN KEEPING W/SAFE LABORATORY
PRACTICES IS RECOMMENDED.
* Physical/Chemical Properties *
Solubility in Water:MODERATE
Appearance and Odor:YELLOW TO ORANGE POWDER; ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, CATIONIC DYES & BLEACHES.
Stability Condition to Avoid:EXTREME HEAT OR FIRE.
Hazardous Decomposition Products:CO*X.
* Disposal Considerations *
Waste Disposal Methods:MATL DOES NOT HAVE EPA WASTE NUMBER & IS NOT A
LISTED WASTE, HOWEVER CONSULTATION W/PERMITTED WASTE DISPOSAL SITE
(TSD) SHOULD BE ACCOMPLISHED. ALWAYS CONTACT PERMITTED WASTE
DISPOSER (TSD) TO ASSURE COMPLIANCE W/ALL CURRENT LOC, STATE & FED
REGS.
| 1 | gloves_mandatory |
Control Measures
*
Proprietary Ind: Y
*
Contractor Summary
*
*
Item Description Information
*
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Signs And Symptions Of Overexposure: SEE HEATLH HAZARDS.
Medical Cond Aggravated By Exposure: NONE KNOWN.
A PHYSICIAN. SKIN CONTACT: WASH AFFECTED AREA WITH SOAP AND WATER. IF
IRRITATION PERSISTS, CONSULT PHYSICIAN. INHALATION: REMOVE TO AN
UNCONTAMINATED AREA, ADMINISTER OXYGEN IF NECESSARY. IF VICTIM HAS STOPPED
BREATHING BEGIN CPR. GET MEDICAL ATTENTION. INGESTION: IF CONSCIOUS, GIVE
WATER OR MILK AND INDUCE VOMITING. SEEK IMMEDIAT E MEDICAL CARE.
*
Handling and Disposal
*
Spill Release Procedures: ABSORB ON SWEEPING COMPOUND OR OTHER ABSORBENT
MATERIAL. KEEP OUT OF STREAMS OR WATERWAYS.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH EXISTING FEDERAL, STATE
AND LOCAL ENVIRONMENTAL REGULATIONS.
Handling And Storage Precautions: AVOID EYE AND SKIN CONTACT. AVOID EXCESSIVE
INHALATION OF VAPORS AND/OR PARTICLE MISTS. USE IN WELL-VENTILATED
*
Fire and Explosion Hazard Information
*
Lower Limits: NE
Upper Limits: NE
Extinguishing Media: WATER, CARBON DIOXIDE OR OTHER DRY CHEMICAL FIRE FIGHTING
AGENTS.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT
(FP N).
Unusual Fire/Explosion Hazard: NONE. FLAMMABILITY RATING: 1.
*
*
Respiratory Protection: A RESPIRATOR WOULD NOT BE REQUIRED FOR OPEN AREAS (NOT
CONFINED) WITH ADEQUATE VENTILATION WHEN SPRAYING. IF NECESSARY A NIOSH
APPROVED DUST/MIST RESPIRATOR TO REMOVE PARTICLE MASS.
Ventilation: ADEQ VENT WOULD INCLUDE "THE OUTDOORS" OR ANY "INDOOR ENVIRONMENT"
W/CONTROLLED TEMP SYS THAT USED FORCE AIR W/HIGH BAYS OR OTHER SIMILAR
CONDITIONS.
Other Protective Equipment: ANSI APPROVED EYE WASH AND DELUGE SHOWER (FP N).
*
Physical/Chemical Properties
*
B.P. Text: N/E
M.P/F.P Text: N/E
Vapor Pres: N/E
Vapor Density: N/E
PH: 9-9.6 (NEAT)
Evaporation Rate & Reference: N/E
Appearance and Odor: MILKY, OFF-WHITE LIQUID; CHARACTERISTIC ODOR.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: CONTACT WITH INCOMPATIBLE MATERIALS.
Materials To Avoid: STRONG ACIDS, ALKALIS AND OXIDIZING AGENTS.
Hazardous Decomposition Products: OXIDES OF CARBON AND NITROGEN.
Hazardous Polymerization Indicator: NO
*
Toxicological Information
*
*
*
Transport Information: DOT/IMDGA/IATA SHIPPING NAME: N/A. UN/NA NUMBER: N/A.
DOT/IMDG/IATA HAZARD CLASS: N/A. TSCA STATUS: LISTED. DOT/IMDGA/IATA
REQUIDED. DOT IMDGA/IATA REQUIRED LABELS: N/A. TECHNICAL SHIPPING NAME: N/A.
*
Other Information
*
Other Information: PRODUCT DESCRIPTION: PROPRIETARY WATERBORNE CORROSION
RESISTANT COATING. NE = NOT ESTABLISHED; NA = NOT APPLICABLE.
*
HAZCOM Label
*
Company Name: THE CORTEC CORPORATION
Label Required IND: Y
Status Code: A
Origination Code: F
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE: REPEATED OR PROLONGED SKIN CONTACT WITH MATERIAL
CAN CAUSE SKIN IRRITATION. EYE CONTACT WITH MATERIAL CAN CAUSE IRRITATION.
EXCESSIVE INHALATION OF HIGH VAPOR CONCENTRATIONS MAY IRRITATE THE UP PER
RESPIRATORY TRACT. IF THE PRODUCT IS SPRAYED OR ATOMIZED, INHALATION OF
PARTICLE MIST MAY IRRITATE UPPER RESPIRATORY TRACT. INGESTION: EXPECTED TO BE
HARMFUL. CHRONIC: NONE SPECIFIED BY MANUFACTUR ER.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH APPROVED DUST RESPIRATOR IF DUST IS
CREATED DURING HANDLING, INSTALLATION OR TEAR OUT.
Ventilation:GOOD GENERAL VENTILATION IS SUFFICIENT FOR MOST CONDITIONS
Other Protective Equipment:EYE WASH STATION, QUICK DRENCH SHOWER AND
IMPERVIOUS CLOTHING
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
* Product Identification *
Product ID:PUROCAST,PUROCAST GM,PUROCAST N
* Composition/Information on Ingredients *
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE
Other REC Limits:NONE SPECIFIED
OSHA PEL:SEE TABLE Z3
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:SEE TABLE Z3
Ingred Name:GROG/ALUMINO-SILICATES
Other REC Limits:NONE SPECIFIED
Ingred Name:CEMENT BINDER
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE- EYE:MAY IRRITATE OR INJURE
EYES. SKIN:REPEATED OR PROLONGED CONTACT MAY CAUSE IRRITATION.
INHALE:LONG TERM EXPOSURE TO RESPIRABLE SILICA MAY PRODUCE
PNEUMOCONIOSIS. ORAL: NONE KNOWN. CHRONIC-MA Y CAUSE
PNEUMOCONIOSIS.
Explanation of Carcinogenicity:INTERNATIONAL RESEARCH ON CANCER (IARC)
HAS CATEGORIZED CRYSTALLINE SILICA AS A CLASS 2A CARCINOGEN.
Effects of Overexposure:MAY IRRITATE OR INJURE EYES. REPEATED OR
PROLONGED SKIN CONTACT MAY CAUSE IRRITATION. LONG TERM EXPOSURE TO
RESPIRABLE SILICA MAY PRODUCE PNEUMOCONIOSIS.
Medical Cond Aggravated by Exposure:PERSONS WITH IMPAIRED RESPIRATORY
FUNCTION MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THE SUBSTANCE.
* First Aid Measures *
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. SKIN:WASH WITH
OPEN. INHALED:REMOVE TO FRESH AIR. ORAL:CALL PHYSICIAN.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:WATER SPRAY, CO2, FOAM/DRY CHEMICAL. WATER SPRAY
MAY BE USED TO KEEP FIRE EXPOSED CONTAINERS COOL & FLUSH SPILLS
AWAY.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS OR DUST RESPIRATOR IF NEEDED.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:USE DUST FREE METHODS OF CLEANUP.
*Handling and Storage *
Handling and Storage Precautions:STORAGE- STORE IN TIGHTLY CLOSED
CONTAINERS. DO NOT RAISE DUSTS.
Other Precautions:KEEP ALL CHEMICALS OUT OF REACH OF CHILDREN. THIS
PRODUCT FOR INDUSTRIAL USE ONLY. AVOID BREATHING DUSTS. DO NOT GET
IN EYES, ON SKIN OR ON CLOTHING. TOXIC RISK MAY BE ALTERED BY
CHEMICAL OR PHYSICAL CHANGES CAUSED BY CONDITIONS OF USE.
* Physical/Chemical Properties *
HCC:N1
Spec Gravity:2.0 - 3.0
Solubility in Water:NIL
Appearance and Odor:GREY, GRANULAR, DRY - NO ODOR
Percent Volatiles by Volume:NIL
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NONE
* Disposal Considerations *
Waste Disposal Methods:FINAL USED PRODUCT SHOULD BE TESTED TO DETERMINE
HAZARD STATUS AND DISPOSED IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/OSHA CHEMICAL/MECHANICAL FILTERS WHEN
VENTILATION IS RESTRICTED.
Ventilation:SUFFICIENT TO KEEP AIR CONTAMINATION 1
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:THIN GREEN LIQUID W/TYPICAL SOLVENT ODOR
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:WET NITROCELLULOSE, NITROCELLULOSE, NITRATE CELLULOSE
Ingred Name:ALKYD RESIN
Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE
Fraction by Wt: 5%
Ingred Name:ETHYL ACETATE
Fraction by Wt: 5%
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL
Ingred Name:2-BUTANONE (METHYL ETHYL KETONE) (MEK)
Ingred Name:LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA, LACOLENE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: LONG TERM EXPOSURE MAY CAUSE
IRRITATION. REACTS W/SKIN PROTEIN & MOISTURE & CAUSE RASH,
SCALING/BLISTERING. INHALATION: ANESTHETIC, MAY CAUSE CENTRAL
NERVOUS SYSTEM EFFECTS, INCLUDING DEATH. ING ESTION: ASPIRATION
INTO THE RESPIRATORYSYSTEM/FROM VOMITING, MAY CAUSE CHEMICAL
PNEUMONIA/PULMONARY EDEMA.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:DRYING, CRACKING, IRRITATION, RASH,
SCALING/BLISTERING OF SKIN, HEADACHES, DIZZINESS
Medical Cond Aggravated by Exposure:PRE-EXISTING SENSITIVITY TO
SOLVENTS.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. SKIN:
FLUSH W/WATER. EYES: FLUSH IMMEDIATELY W/LARGE AMOUNTS OF WATER.
INGESTION: DON'T INDUCE VOMITING. KEEP WARM & QUIET. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:SCC
Flash Point:-4F
Lower Limits:0.9
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:DON'T USE WATER HOSE STREAM. WATER MAY BE USED
TO COOL CLOSED CONTAINERS. USE HELMET W/FACE SHIELD/BUNKER COAT,
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. WATER STREAM WILL SPREAD FIRE. VAPOR IS
>AIR, TRAVEL CONSIDERABLE DISTANCE TO IGNITION SOURCE/FLASH.
* Accidental Release Measures *
Spill Release Procedures:AVOID BREATHING SOLVENT VAPOR. ENSURE ADEQUATE
VENTILATION. AVOID IGNITION SOURCES. ELIMINATE SOURCE OF LEAK W/O
RISK BY CLOSING VALVE/PLUGGIN HOLE. APPLY ABSORBENT. CLEAN
W/BRISTLE BROOMS, NON-SPARKI NG TOOLS, CLEAN DRY RAGS. USE
PROTECTIVE CLOTHING.
*Handling and Storage *
Handling and Storage Precautions:DRUMS SHOULD BE GROUNDED WHEN BEING
EMPTIED. PROVIDE RESPIRATORY PROTECTION AGAINST FUMES GENERATED
DURING BURNING.
Other Precautions:DON'T BREATHE THE VAPORS/HAVE CONTACT W/EYES/SKIN.
PROTECT AGAINST EXPOSURE TO BOTH VAPOR & SPRAY MIST.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:NO
STRONG OXIDIZERS, ACIDS & ALKALIES
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME & OTHER IGNITION
SOURCES
Hazardous Decomposition Products:CO, CO2
* Disposal Considerations *
Waste Disposal Methods:DON'T INCINERATE, CUT/WELD EMPTY CONTAINERS.
WHEN DISCARDED, THIS MATERIAL IS A HAZARDOUS WASTE. TRANSFER LIQUID
TO CONTAINERS FOR RECOVERY/DISPOSAL IN ACCORDANCE W/LOCAL, STATE &
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH-APPROVED DUST RESPIRATORS IF TLV >5 MG/CUM
Ventilation:LOCAL EXHAUST/MECHANICAL
Other Protective Equipment:FULL LENGTH CLOTHING HELP PREVENT CONTACT
WITH BODY MOISTURE
Supplemental Safety and Health
* Product Identification *
Product ID:LITHIUM CARBONATE
* Composition/Information on Ingredients *
Ingred Name:LITHIUM CARBONATE
ACGIH TLV:5 MG/CUM-DUST
* Hazards Identification *
Effects of Overexposure:INHALATION OR INGESTION OF LARGE DOSES: TREMOR
AND NAUSEA.
* First Aid Measures *
First Aid:SKIN: PRACTICE PROPER HYGIENE. EYES: FLUSH THOROUGHLY WITH
* Fire Fighting Measures *
Flash Point:NOT FLAMMABLE
Extinguishing Media:NOT FLAMMABLE
Fire Fighting Procedures:NOT FLAMMABLE
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP AND RETURN TO CONTAINER. SMALL
QUANTITIES MAY BE WASHED AWAY WITH WATER. WE PERSONAL PROTECTIVE
EQUIPMENT DURING CLEANUP.
*Handling and Storage *
Handling and Storage Precautions:THOROUGHLY CLEAN EQUIPMENT BEFORE
REPAIRS. WASH OUT W/WATER & COLLECT THE SOLUTION IN STORAGE
NTAINERS.
Other Precautions:WEAR PROTECTIVE EQUIPMENT DURING CLEANUP OR REPAIR TO
PREVENT THE LITHIUM CARBONATE FROM CONTACT WITH SKIN & EYES.
* Physical/Chemical Properties *
Vapor Pres:0
Solubility in Water:SLIGHT
Appearance and Odor:WHITE GRANULES OR POWDER. ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CONCENTRATED ACIDS
* Disposal Considerations *
Waste Disposal Methods:FOLLOW STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NEEDED
Ventilation:LOCAL OR POINT OF OPERATION
Other Protective Equipment:APRONS
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:NICKEL (ANTIMONY, TITANIUM YELLOW PIGMENT)
Other REC Limits:A2 CARCINOGEN
OSHA PEL:1.0 MG/CUM
ACGIH TLV:0.5 MG/CUM
Ingred Name:SILVER (SARA III)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:COPPER (SARA III)
Other REC Limits:1 MG(CU)/M3 (DUST)
OSHA PEL:0.1MG/M3 FUME/1 DUST
Ingred Name:PLATINUM SOLUBLE SALTS
ACGIH TLV:1 MG/CUM
Ingred Name:INDIUM
OSHA PEL:0.1 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Explanation of Carcinogenicity:NICKEL IS CONSIDERED TO BE AN A2
CARCINOGEN.
Medical Cond Aggravated by Exposure:WILSON'S DISEASE (COPPER)
* First Aid Measures *
First Aid:INHALATION: MOVE TO FRESH AIR, SEEK MEDICAL ATTENTION IF
NECESSARY. INGESTION: DILUTE W/LARGE AMOUNTS OF WATER, SEEK MEDICAL
ATTENTION. EYES: FLUSH W/WATER. SKIN: NOT HAZARDOUS CONDITION.
* Fire Fighting Measures *
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE.
* Accidental Release Measures *
Spill Release Procedures:SWEEP/VACUUM SOLIDS, DON'T RAISE DUST.
*Handling and Storage *
Handling and Storage Precautions:AVOID CREATING EXCESSIVE DUST WHILE
GRINDING.
Other Precautions:NONE
* Physical/Chemical Properties *
Solubility in Water:INSOLUBLE
Appearance and Odor:GOLD COLORED ALLOY
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Hazardous Decomposition Products:NONE UNDER PROPER USAGE CONDITIONS
* Disposal Considerations *
Waste Disposal Methods:RE-USE/DISPOSE ACCORDING TO LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF EXPOSURE CAN'T BE CONTROLLED BELOW APPLICABLE
LIMITS, WEAR A PROPERLY FITTED ORGANIC VAPOR/PARTICULATE
RESPIRATOR/WHEN SANDING/WIREBRUSHING/ABRADING/BURNING/WELDING THE
DRIED FILM, WEAR A PARTICULA TE RESPIRATOR APPROVED BY NIOSH/MSHA.
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE TO
MAINTAIN BELOW APPLICABLE EXPOSURE LIMITS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS AFTER USING. USE ONLY ADEQUATE VENTILATION.
Supplemental Safety and Health
HLTH HZRD: ALCOHOLS & ACETATES CAN BE ABSORBED. DISPOSAL: DON'T
INCINERATE CLOSED CONTAINERS. PRECAUTIONS: AVOID BREATHING VAPOR &
SPRAY MIST. AVOID CONTACT W/SKIN & EYES. VAPOR PRESSURE IS FOR
MINERA L SPIRITS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
Ingred Name:POTASSIUM ZINC CHROMATE (CONFIRMED HUMAN CARCINOGEN BY
Fraction by Wt: 6%
Ingred Name:CHROMIUM COMPOUNDS (TYPE NOT SPECIFIED)
Fraction by Wt: 6%
Ingred Name:ZINC COMPOUND
Fraction by Wt: 6%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF EYES, SKIN & RESPIRATORY
SYSTEM, NERVOUS SYSTEM DEPRESSION & DEATH. PROLONGED OVEREXPOSURE
TO SOLVENT MAY CAUSE ADVERSE EFFECTS TO THE LIVER, URINARY, BLOOD
FORMING, CARDIO-VASCULAR & RE PRODUCTIVE SYSTEM. REPEATED/PROLONGED
OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT BRAIN & NERVOUS SYSTEM
DAMAGE. (SUPP)
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, NAUSEA, LOSS
OF COORDINATION, REDNESS, ITCHING, BURNING, ABDOMINAL DISCOMFORT,
PAIN, CONSTIPATION, LOSS OF APPETITE, METALLIC TASTE, INSOMNIA,
WEAKNESS, MUSCLE & JOINT PAINS.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. KEEP WARM
& QUIET. SKIN: WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH W/LARGE
MOUTH T O AN UNCONSCIOUS PERSON. DON'T INDUCE VOMITING. GIVE
SEVERAL GLASSES OF WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Lower Limits:0.5
Upper Limits:7.5
Extinguishing Media:CO2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIPMENT & SCBA. WATER
SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE. WATER MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE DUE TO
EXTREME HEAT. TAKE SPECIAL PRECAUTIONS W/HOT SURFACES. OVEREXPOSURE
TO DECOMPOSITION MAY CAUSE A HEALTH HAZARD.
* Accidental Release Measures *
Spill Release Procedures:REMOVE SOURCES OF IGNITION. VENTILATE & REMOVE
W/INERT ABSORBENT.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & OPEN
FLAME. KEEP CONTAINER CLOSED WHEN NOT IN USE. USE APPROVED BONDING
& GROUND PROCEDURES. DON'T TAKE INTERNALLY.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. DON'T APPLY ON
EXTERIOR SURFACE OF DWELLING UNITS/WINDOW
SILLS/PORCHES/STAIRS/RAILINGS/TOYS/FURNITURE. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING & INHALING THE CO NTENTS CAN BE
HARMFUL/FATAL. (SEE SUPP)
* Physical/Chemical Properties *
Vapor Pres:2
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:BY FIRE: CO2, CO, OXIDES OF METALS.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE/DISPOSE OF IN AN APPROVED FACILITY,
IAW/FEDERAL, STATE & LOCAL REGULATIONS. WASTE MAY BE HAZARDOUS
UNDER THE RCRA & MUST BE TESTED FOR IGNITABILITY TO APPLICABLE EPA
HAZARDOUS WASTE. LEAD/C HROMIUM MUST ALSO BE TESTED. (SUPP)
| 1 | gloves_mandatory |
Control Measures
*
Cage: 0FTT5
*
Preparer Co. when other than Responsible Party Co.
*
Cage: 0FTT5
*
Contractor Summary
*
Cage: 0FTT5
*
Item Description Information
*
Item Manager: GSA
Item Name: ENAMEL
Unit of Issue: PT
UI Container Qty: B
*
Ingredients
*
Other REC Limits: NONE SPECIFIED
------------------------------
Other REC Limits: NONE SPECIFIED
OSHA PEL: NOT ESTABLISHED
------------------------------
Other REC Limits: NONE SPECIFIED
------------------------------
Other REC Limits: NONE SPECIFIED
------------------------------
Other REC Limits: NONE SPECIFIED
------------------------------
Other REC Limits: NONE SPECIFIED
------------------------------
Other REC Limits: NONE SPECIFIED
OSHA PEL: NOT ESTABLISHED
------------------------------
Other REC Limits: NONE SPECIFIED
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: CONCENTRATING & INHALING CONTENTS HARMFUL/FATAL.
REPEATED/PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS W/PERMANENT BRAIN
& NERVOUS SYSTEM DAMAGE. IN CONFINED AREAS VAPORS IN HIGH CONCENTRATION
ANES THETIC. SKIN & RESP TRACT IRRITATION. LIGHT HEADED, STAGGER,
GIDDINESS, NAUSEA. HARMFUL IF SWALLOWED. SEVERE EYE IRRIT.
Signs And Symptions Of Overexposure: IRRITATION TO EYES, THROAT, AND
RESPIRATORY TRACT. MAY CAUSE HEADACHES, NAUSEA, AND VOMITING.
Medical Cond Aggravated By Exposure: RESPIRATORY AILMENTS.
First Aid: FOR CONTACT WITH SKIN OR CLOTHES WASH WITH SOAP & WATER; WASH
& CONTACT A PHYSICIAN/OPHTHALMOLOGIST IMMEDIATELY. IF SWALLOW ED, DO NOT
INDUCE VOMITING. GET IMMEDIATE MEDICAL AID. IF INHALED, REMOVE TO FRESH AIR
& GIVE ARTIFICIAL RESPIRATION IF NECESSARY & GET MEDICAL AID. NEVER
GIVE ANYTHING BY MOUTH TO UNCONSCIOUS PERSON.
*
Handling and Disposal
*
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION AND VENTILATE AREA.
MOP SPILLS WITH INERT ABSORBENT. AVOID BREATHING VAPORS.
Waste Disposal Methods: DISPOSE OF IN ACCORD WITH FEDERAL, STATE, & LOCAL
OR PROLONGED EXPOSURE TO SUN MAY CAUSE CAN TO BURST. DISCARD EMPTY CAN IN TR
ASH PICK-UP. DON'T PLACE IN HOME TRASH COMPACTOR.
Handling And Storage Precautions: KEEP OUT OF REACH OF CHILDREN. CONTENTS UNDER
SPRAY, MIST OR VAPOR.
Other Precautions: AVOID CONTACT WITH SKIN OR EYES. USE WITH GOOD VENTILATION.
READ ENTIRE LABEL BEFORE USING. FOLLOW AL LABEL DIRECTIONS. INTENTIONAL
MISUSE BY DELIBERATELY CONCENTRATING & INHALING OR SWALLOWING CONTEN TS
MAY BE HARMFUL OR FATAL.
*
Fire and Explosion Hazard Information
*
Flash Point Text: NR
Lower Limits: 1.8
Upper Limits: 9.5
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, SAND, WATER SPRAY.
AVOID SPREADING ANY BURNING LIQUID WITH WATER SPRAY.
Fire Fighting Procedures: WATER MAY BE INEFFECTIVE, USE WATER TO COOL FIRE
EXPOSED CONTAINERS. WEAR SCBA. USE SHIELDING TO PROTECT PERSONNEL FROM
BURSTING, RUPTURING, CONTAINER VENTING.
Unusual Fire/Explosion Hazard: DON'T SPRAY NEAR OPEN FLAME. AT ELEVATED
*
*
Respiratory Protection: NONE BELOW TLV. USE NIOSH/MSHA APPROVED MASK ABOVE TLV.
Ventilation: LOCAL EXHAUST: PREFERRED. MECHANICAL (GENERAL): ACCEPTABLE AT
POINT OF MIST OR SPRAY RELEASE.
Other Protective Equipment: IMPERVIOUS CLOTHES TO PROTECT SKIN. EYE WASH
STATION.
Work Hygienic Practices: USE GOOD PERSONAL HYGIENE. DO NOT EAT DRINK OR SMOKE
WHILE USING PRODUCT.
*
Physical/Chemical Properties
*
HCC: V3
Vapor Density: >1.5
Solubility in Water: INSOLUBLE
Appearance and Odor: FLAT BLACK PAINT
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: EXTREME HEAT
Hazardous Decomposition Products: CARBON MONOXIDE, AND POSSIBLE HYDROGEN
CHLORIDE
Hazardous Polymerization Indicator: NO
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
Transportation Information
*
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: PT
Container QTY: B
*
Detail DOT Information
*
DOT PSN Code: DTJ
Symbols: D
DOT Proper Shipping Name: CONSUMER COMMODITY
Hazard Class: ORM-D
Label: NONE
Bulk Pack: NONE
Vessel Stow Req: A
*
Detail IMO Information
*
IMO PSN Code: AKH
IMO Proper Shipping Name: AEROSOLS/AEROSOL PRODUCT ?
UN Hazard Class: 9?
IMO Packaging Group: -
Subsidiary Risk Label: -
*
Detail IATA Information
*
IATA PSN Code: ALS
IATA Proper Shipping Name: AEROSOLS, FLAMMABLE
IATA PSN Modifier: (EACH NOT EXCEEDING 1 L CAPACITY)
IATA UN Class: 2.1
IATA Label: FLAMMABLE GAS
*
Detail AFI Information
*
AFI PSN Code: ALR
AFI Symbols: *
AFI Proper Shipping Name: AEROSOLS, FLAMMABLE, N.O.S.
AFI PSN Modifier: (EACH NOT EXCEEDING 1L CAPACITY)
AFI Hazard Class: 2.1
Special Provisions: P4
Back Pack Reference: A6.3
*
HAZCOM Label
*
Cage: 0FTT5
Company Name: LHB INDUSTRIES
Label Required IND: Y
Status Code: C
Origination Code: G
Hazard And Precautions: CONCENTRATING & INHALING CONTENTS HARMFUL/FATAL.
REPEATED/PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS W/PERMANENT BRAIN
& NERVOUS SYSTEM DAMAGE. IN CONFINED AREAS VAPORS IN HIGH CONCENTRATION
ANES THETIC. SKIN & RESP TRACT IRRITATION. LIGHT HEADED, STAGGER,
GIDDINESS, NAUSEA. HARMFUL IF SWALLOWED. SEVERE EYE IRRIT. IRRITATION TO
EYES, THROAT, AND RESPIRATORY TRACT. MAY CAUSE HEADACHES, NAUSEA, AND
VOMITING.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:FACE MASK TO AVOID BREATHING DUST.
Other Protective Equipment:APRON
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:PROPRIETARY INGREDIENT
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TOXIC BY INGESTION. SKIN/EYES:
IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN/EYES: IRRITATION.
* First Aid Measures *
INGESTION: INDUCE VOMITING - GIVE 2 GLASSES OF WATER & STICK FINGER
DOWN THROAT. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:WATER, FOAM, DRY CHEMICAL, CO2.
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP & RECOVER. FLUSH AREA W/WATER.
*Handling and Storage *
KEEP CONTAINER & PLASTIC LINER CLOSED WHEN NOT IN USE. AVOID
CONTACT W/METAL SCOOPS, MILLS OR SIEVES.
* Physical/Chemical Properties *
Vapor Pres:0
Solubility in Water:COMPLETE
Appearance and Odor:WHITE CRYSTALS; SLIGHT CHARACTERISTIC ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:NO
ALKALIS, AMINES, & METAL
Hazardous Decomposition Products:FORMALDEHYDE, BROMINE, OXIDES OF
CARBON & NITROGEN.
* Disposal Considerations *
Waste Disposal Methods:BURY IN APPROVED SANITARY LANDFILL IN ACCORDANCE
W/LOCAL, FEDERAL, STATE REGULATIONS. WHEN IN SOLUTION,
DECOMPOSITION CAN BE EFFECTED BY TREATMENT W/CAUSTIC & HEATING
(ONLY BY SKILLED PERSONNEL).
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:IMPERVIOUS PROTECTIVE CLOTHING. SAFETY
SHOWER AND EYE BATH.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SELENIUM (SARA III)
OSHA PEL:0.2 MG/M3
ACGIH TLV:0.2 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: HARMFUL IF SWALLOWED, INHALED,
OR ABSORBED THROUGH SKIN. EXPOSURE CAN CAUSE STOMACH PAINS,
VOMITING, DIARRHEA, COUGHING, CHEST PAINS, DIFFICULTY IN BREATHING,
LUNG IRRITATION, DERMATITIS.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
MINS. ASSURE ADEQ FLUSHING BY SEPARATING EYELIDS WITH FINGERS.
MINUTES WHILE REMO VING CONTAMINATED CLOTHING AND SHOES. DISCARD
CONTAMD CLTHG & SHOES. INHAL: REMOVE TO FRESH AIR. IF NOT BRTHG
GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE OXYGEN. CALL PHYS. INGEST:
CALL MD IMMED .
* Fire Fighting Measures *
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE TO SURROUNDING
FIRE CONDITIONS. NONCOMBUSTIBLE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
* Accidental Release Measures *
Spill Release Procedures:EVAC AREA. WEAR NIOSH/MSHA APPROVED
SELF-CONTAINED BREATHING APPARATUS, RUBBER BOOTS AND HEAVY RUBBER
RAISING DUST. VENTILATE AREA AND WASH SPILL SITE AFTER MATERIAL
PICKUP IS COMPETE.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:KEEP TIGHTLY CLOSED.
Other Precautions:TOXIC. HARMFUL DUST. READILY ABSORBED THROUGH SKIN.
DO NOT BREATHE DUST. AVOID CONTACT AND INHALATION. DO NOT GET IN
EYES, ON SKIN, ON CLOTHING.
* Physical/Chemical Properties *
Appearance and Odor:
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, CONTACT WITH ACID.
Stability Condition to Avoid:
Hazardous Decomposition Products:TOXIC FUMES.
* Disposal Considerations *
Waste Disposal Methods:MATERIAL IN ELEMENTAL STATE SHOULD BE RECOVERED
FOR REUSE OR RECYCLING. OBSERVE ALL FEDERAL, STATE AND LOCAL LAWS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SELECT APPROPRIATE NIOSH-APPROVED RESPIRTORY
PROTECTION WHERE NECESSARY TO MAINTAIN EXPOSURES BELOW THE
ACCEPTABLE LIMITS. PROPER RESPIRATORY SELECTION SHOULD BE
DETERMINED BY ADEQUATE TRAINED PERSONN EL AND BASED ON THE
CONTAMINANTS, ETC.
Ventilation:GENERAL MECANICAL VENTILATION NORMALLY ADEQUATE.
Other Protective Equipment:CLOTHING TO MINIMIZE SKIN EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. WASH CLOTHING
AFTER USE.
Supplemental Safety and Health
NONE
* Product Identification *
Preparer's Name:SAFETY, HEALTH & ENV.
* Composition/Information on Ingredients *
Ingred Name:HYDROTREATED MIDDLE PETROLEUM DISTILLATE
Other REC Limits: RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION- EXTREME EXPOSURE OR
ASPIRATION INTO THE LUNGS MAY CAUSE PNEUMONIA. SKIN- IRRITATION.
EYES- IRRITATION.
Effects of Overexposure:OVEREXPOSURE MAY CAUSE WEAKNESS, HEADACHE,
NAUSEA, CONFUSION, BLURRED VISION, DROWSINESS AND OTHER NERVOUS
SYSTEM EFFECTS. GREATER EXPOSURE MAY CAUSE DIZZINESS, SLURRED
SPEECH, FLUSHED FACE, UNCONSCIO USNESS OR CONVULSIONS.
Medical Cond Aggravated by Exposure: SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHALATION- REMOVE TO FRESH AIR. ASSIST WITH BREATHING
SUPPORT MEASURES, IF NEEDED. SKIN- FLUSH WITH WATER AFTER CONTACT.
WASH CONTAMINATED CLOTHING BEFORE REUSE. EYES- IMMEDIATELY FLUSH
INDUCE VOMITING. IF CONSCIOUS, IMMEDIATELY GIVE TWO GLASSES OF
WATER. CALL A PHYSICIAN.
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:1.0
Upper Limits:6.0
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:WATER OR FOAM MAY CAUSE FROTHING. USE WATER TO
KEEP FIRE-EXPOSED CONTAINERS COOL. DO NOT ENTER ENCLOSED OR
CONFINED SPACE WITHOUT PROPER PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:WATER SPRAY MAY BE USED TO FLUSH SPILLS
AWAY FROM EXPOSURES. PRODUCTS OF COMBUSTION MAY INCLUDE TOXIC
MATERIALS.
* Accidental Release Measures *
Spill Release Procedures:REMOVE SOURCE OF HEAT, SPARKS, FLAME, IMPACT,
FRICTION OR ELECTRICITY. DIKE SPILL. PREVENT LIQUID FROM ENTERING
SEWERS, WATERWAYS OR LOW AREAS. RECOVER FREE LIQUID FOR REUSE OR
RECLAMATION. SOAK UP WI TH SAWDUST, SAND, OIL DRY OR OTHER
ABSORBENT.
*Handling and Storage *
Handling and Storage Precautions:STORE IN ACCORDANCE WITH NATIONAL FIRE
PROTECTION ASSOCIATION REGULATIONS.
Other Precautions:
* Physical/Chemical Properties *
HCC:N1
Vapor Pres:0.4
Vapor Density:6.2
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID.
Percent Volatiles by Volume:NIL
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS.
Stability Condition to Avoid:EXCESSIVE HEAT AND FLAME.
Hazardous Decomposition Products:CARBON DIOXIDE AND POSSIBLY CARBON
MONOXIDE.
Conditions to Avoid Polymerization:POLYMERIZATION WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:TREATMENT, STORAGE, TRANSPORTATION AND DISPOSAL
MUST BE IN ACCORDANCE WITH APPLICABLE FEDERAL, STATE/PROVINCIAL,
AND LOCAL REGULATIONS. RECOVER NONUSABLE FREE LIQUID AND DISPOSE OF
IN AN APPROVED ANDPERMITTED INCINERATOR.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR SUITABLE FOR
ORGANIC VAPORS IF NECESSARY.
Ventilation:PROVIDE ADEQUATE CROSS AIR CIRCULATION. EXHAUST AT POINT OF
USE.
Other Protective Equipment:IMPERMEABLE APRON OR GARMENT. EYEWASH
STATION, EMERENCY SHOWERS.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING.
Supplemental Safety and Health
* Product Identification *
CAGE:BELZO
CAGE:BELZO
* Composition/Information on Ingredients *
Ingred Name:PHENOL, POLYMER WITH FORMALDEHYDE, GLYCIDYL ETHER
Ingred Name:TITANIUM DIOXIDE
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES/SKIN: IRRITATION, SENSITIZER
* First Aid Measures *
First Aid:SKIN: WASH W/WATER & SOAP. REMOVE COMTANINATED CLOTHING. CALL
A PHYSICIAN OR TAKE TO A HOSPITAL IMMEDIATELY. INGESTION: DRINK
LARGE QUANTITIES OF WATER IMMEDIATELY. INHALATION: MOVE TO FRESH
AIR & GIV E ARTIFICIAL RESPIRATION IF NECESSARY.
* Fire Fighting Measures *
Flash Point Method:SCC
Extinguishing Media:WATER FOG (NOT A DIRECT STREAM OF WATER), FOAM,
CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING. USE SELF CONTAIANED
BREATHING APPARATUS. DECONTAMINATE CLOTHING AFTER USE.
Unusual Fire/Explosion Hazard:DECOMPOSITION & COMBUSTION PRODUCTS MAY
BE HAZARDOUS.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. USE SAND TO
ABSORB SPILLED MATERIAL & DISPOSE OF PROPERLY. TRANSFER TO CLOSED
METAL CONTAINER. AVOID ALL PERSONAL CONTACT.
*Handling and Storage *
Handling and Storage Precautions:MUST BE KEPT IN DRY, COOL & COVERED
AREA. AVOID BREATHING VAPORS. DISCARD CONTAMINATED SHOES.
Other Precautions:CHECK ALL CONTAINERS FOR LEAKS. AVOID BREATHING
VAPORS OR CONTACT WITH SKIN.
* Physical/Chemical Properties *
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN N-BU AC
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE VISCOUS LIQUID W/SLIGHT ODOR.
Percent Volatiles by Volume:0.0%
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:SOURCE OF IGNITIONS
Hazardous Decomposition Products:OXIDES OF CARBON, ALDEHYDES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IN OUTDOOR/OPEN AREAS, USE NIOSH/MSHA APPRVD
MECH FILTER RESP TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY
DURING SPRAY APPLICATION. IN RESTRICTED VENT AREAS, USE NIOSH/MSHA
APPRVD CHEM-MECH FILTER S DESIGNED TO REMOVE COMBINATION(SUPDAT)
Ventilation:USE VENT AS REQD TO CONTROL VAP CONCS. AVOID PRLNG/RPTD
BRTHG OF VAPS. IF EXPOS EXCEEDS TLV, USE NIOSH/MSHA (ING 5)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS THORO BEFORE EATING & USING
WASHROOM. REMOVE CONTAM CLTHG IMMED & DO NOT WEAR IT UNTIL IT HAS
BEEN (ING 8)
Supplemental Safety and Health
FIRST AID PROC:SYRUP OF IPECAC UNDER DIRECTION FROM MD/POIS CTR. IF
SYRUP OF IPECAC IS NOT AVAIL, VOMIT CAN BE INDUCED BY GENTLY PLA
CING TWO FINGERS INTO BACK OF THROAT. IF POSS, DO NOT LEAVE VICTIM
UNATTENDED. RESP PROT:OF PARTICULATE & GAS & (ING 3)
* Product Identification *
* Composition/Information on Ingredients *
OSHA PEL:N/K
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SUPDAT:VAP. IN CONFINED AREAS, USE NIOSH/MSHA APPRVD AIR
LINE RESPS/HOODS. NIOSH/MSHA APPRVD RESP PROT MAY ALSO (ING 4)
Ingred Name:ING 3:BE NEC IN ANY LATER MFG OPERATIONS IN WHICH THESE
PRODS MAY BECOME AIRBORNE IN THE FORM OF VAPOR OR DUST.
Ingred Name:VENT:APPRVD RESP TO PVNT OVEREXP. PROVIDE GEN DILUTION/LOC
EXHST VENT IN VOL & PATTERN TO KEEP TLV OF MOST HAZ (ING 6)
Ingred Name:ING 5:INGS BELOW ACCEPT LIM, LEL BELOW STATED LIM & TO
REMOVE DECOMP PRODS DURING WELDING/FLAME CUTTING ON SURFS (ING 7)
Ingred Name:ING 6:COATED W/THESE PRODUCTS.
Ingred Name:HYGIENE PRACT:PROPERLY LAUNDERED.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:REPORTS HAVE ASSOC RPTD & PRLNG OCCUP
OVEREXP TO SOLVS W/PERM BRAIN & NERV SYS DMG. INTENTIONAL MISUSE BY
DELIB CONCENTRATING & INHALING CONTENTS MAY BE HARMFUL/FATAL. DO
NOT BREATHE VAPS/SPRAY MIST, WEAR AN APPROP, PROPERLY FITTED
NIOSH/MSHA APPRVD RESP DURING & AFTER APPLICATIONS UNLESS AIR (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:MONITORING DEMONSTRATES VAP/MIST
LEVELS ARE BELOW APPLIC LIMS. FOLLOW RESP MFR'S DIRECTIONS FOR RESP
USE. BASED ON PRESENCE OF ING 1, THESE PRODS CAN BE IRRIT TO EYES.
THESE PRODS CONTAIN ONE /MORE REPORTED TERATOGENS/SUSPECTED
TERATOGENS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
IMMED. SKIN:FLUSH WASH W/COPIOUS AMTS OF LUKE WARM WATER, REMOVE
CONTAM CLTHG PROMPTLY, CONT MD IMMED. INHAL:REMOVE EXPOS INDIVIDUAL
TO FRESH AI R, CONT MD IMMED. INGEST:NEVER GIVE ANYTHING BY MOUTH
TO UNCON PERS, IF VICTIM IS CONSCIOUS & ALERT, VOMIT SHOULD BE
INDUCED FOR INGESTS FOR MORE THAN 1 SWALLOW (1-2 TBSPS FOR ADULT)
PREF W/ (SUPDAT)
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CONTAINERS EXPOSED TO INTENSE HEAT FROM
FIRES SHOULD BE COOLED W/WATER TO PREVENT VAPOR PRESSURE BUILDUP
WHICH COULD RESULT IN CONTAINER RUPTURE.
* Accidental Release Measures *
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP FROM FREEZING. DO NOT STORE
OF THE REACH OF CHILDREN.
Other Precautions:THESE PRODUCTS CONTAIN PIGMENTS WHICH MAY BECOME A
DUST NUISANCE WHEN REMOVED BY ABRASIVE BLASTING, SANDING OR
GRINDING.
* Physical/Chemical Properties *
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
THESE PRODUCTS ARE INCOMPATIBLE W/STRONG ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY PRODUCE HAZ FUMES WHEN HEATED TO
DECOMP. FUMES MAY CONTAIN CARBON MONOXIDE, CARBON DIOXIDE & OXIDES
OF NITROGEN.
* Disposal Considerations *
Waste Disposal Methods:DO NOT FLUSH TO SEWER, WATERSHED OR WATERWAY.
DISPOSE OF THESE PRODUCTS I/A/W APPLICABLE LOCAL, COUNTY, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Ventilation:MECHANICAL PARTICULATE FILTER.
Other Protective Equipment:WASH CONTAMINATED CLOTHING.
Work Hygienic Practices:AVOID PROLONGED OR REPEATED CONTACT. DO NOT
BREATH VAPORS.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Product ID:KT PAINT WHITE
CAGE:BROCK
CAGE:BROCK
* Composition/Information on Ingredients *
Ingred Name:ACETIC ACID, BUTYL ESTER;(N-BUTYL ACETATE)
Ingred Name:ISOBUTYL ALCOHOL;(ISOBUTANOL)
Ingred Name:LIGROINE;(V.M. & P. NAPTHA)
Ingred Name:ETHANOL, 2-BUTOXY-;(GLYCOL ETHER EB ACETATE)
Ingred Name:ISOPROPYL ALCOHOL; (ISOPROPANOL)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ANESTHETIC, IRRITATION OF RESPIRATORY
TRACT OR NERVOUS SYSTEM. INGESTION OF LARGE AMOUNTS MAY CASUE LEAD
POISINING. CONTACT WITH SKIN MAY CAUSE DERMATITIS/EYE CONTACT MAY
CAUSE IRRITATION. ANIMAL STUD IES HAVE CLEARLY DEMONSTRATED
DOSE-RELATED ADVERSE EFFECTS ON THE CNS, THE HEMATOPOIETIC TISSUE,
THE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:BLOOD, THE KIDNEYS, AND THE LIVER
ASSOCIATED WITH THE ADMINISTRATION OF ETHYLENE GLYCOL MONOBUTYL
DEPRESSION, HEADACH E, DIZZINESS, NAUSEA.
* First Aid Measures *
First Aid:INHAL:REMOVE FROM EXPOSURE & RESTORE BREATHING, SEEK MEDICAL
IF IRRITATION RESULTS. INGEST:CALL MD IMMEDIATELY . SKIN:FLUSH WIT
* Fire Fighting Measures *
Lower Limits:0.9
Extinguishing Media:FOAM, ALCOHOL, FOAM, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE, BUT WATER
SPRAY MAY BE USED TO COOL CONTAINERS EXPOSED TO HEAT OR FIRE. WEAR
NIOSH/MSHA APPROVED SCBA & FULL PROT EQUIP .
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AREA
AND SOAK UP WITH INERT ABSORBENT USING NON-SPARKING TOOLS.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:ALL AREAS SHOULD BE ADEQUATELY
SPARKS, OR FLAME.
Other Precautions:DO NOT ALLOW TO COME IN CONTACT WITH EYES OR SKIN.
AVOID PROLONGED EXPOSURE TO VAPORS. DO NOT TAKE INTERNALLY. DO NOT
SMOKE WHILE USING.
* Physical/Chemical Properties *
HCC:F3
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NO
Appearance and Odor:STRONG LAQUER ODOR. COLOR AND CONSISTENCY VARIES.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIM BY VENT, WEAR PROPERLY FITTED ORG VAP/PARTICULATE RESP
APPRVD BY NIOSH/MSHA. WHEN SANDING/ABRADING DRIED FILM, WEAR
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPTABLE IF EXPOS TO MATLS IS <
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC:PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLOS WHEN EXPOS
TO EXTREME HEAT. EXPLO HAZ:REQS SPECIAL PREC. DURING EMER CNDTNS
OVEREXP TO DECOMP PRODS MAY CAUSE HLTH HAZ. SYMP MAY NOT BE IMME D
APPARENT. OBTAIN MED ATTN. HNDLG/STORPREC:PILOT LIGHTS & HEATERS.
TURN OFF STOVES, ELEC TOOLS & APPLIANCES (ING 5)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (MINERAL SPIRITS) VP:
2
Ingred Name:XYLENE (SARA III)VP: 5.9
Fraction by Wt: 1%
Fraction by Wt: 1%
LBS/GAL
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:& ANY OTHER SOURCES OF IGNIT. CONSULT NFPA CODE. USE
APPRVD BONDING & GROUNDING PROC. KEEP CNTNR CLSD (ING 6)
Ingred Name:ING 5:WHEN NOT IN USE. TRANSFER ONLY TO APPRVD CNTNRS
W/COMPLETE & APPROP LABELING. DO NOT TAKE INTERNALLY. KEEP (ING 7)
Ingred Name:ING 6:OUT OF THE REACH OF CHILDREN.
Ingred Name:OTHER PREC:ONLY W/ADEQ VENT. AVOID BRTHG VAP & SPRAY MIST.
AVOID CNTCT W/SKIN & EYES. COATING MAY CONTAIN MATL (ING 9)
Ingred Name:ING 8:CLASS AS NUISANCE PARTICULATES WHICH MAY BE PRESENT @
Ingred Name:RESP PROT:GENERATED FROM THIS PROD, UNDERLYING PAINT OR THE
ABRASIVE.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRIT OF EYES, SKIN & RESP SYS.
MAY CAUSE NERVOUS SYS DEPRESSION. EXTREME OVEREXP MAY RESULT IN
UNCONSCIOUSNESS & POSSIBLY DEATH. HEADACHE, DIZZINESS, NAUSEA &
LOSS OF COORDINATION ARE INDICATI ONS OF EXCESSIVE EXPOSURE TO
VAPORS/SPRAY MISTS. REDNESS & ITCHING OR BURNING SENSATION MAY
INDICATE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:EYE OR EXCESSIVE SKIN EXPOSURE.
CHRONIC: PROLONGED OVEREXPOSURE TO SOLVENT INGREDS IN PRODUCT MAY
CAUSE ADVERSE EFFECTS TO LIVER, URINARY, BLOOD-FORMING,
CARDIOVASCULAR & REPRODUCTIVE SYSTEMS . REPORTS HAVE ASSOCIATED
REPEATED & PROLONGED OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN
& NERVOUS SYSTEM DAMAGE.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
* First Aid Measures *
First Aid:INHALATION: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE
BREATHING. KEEP WARM & QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY
WITH SOAP & WATER. REMOVE CONTAMINATED CLOTHING & LAUNDER BEFORE
RE-USE. EYES: FLUSH EYES WITH LARGE AMOUNTS OF WATER FOR AT LEAST
ATTENTION.
* Fire Fighting Measures *
Lower Limits:0.9%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
WATER SPRAY MAY BE INEFTIVE. IF WATER USED, FOG NOZZ PREF. WATER
MAY BE USED TO COOL CLSD CNTNRS TO (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPK & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOS TO EXTREME HEAT. APPLICATN TO HOT SURF (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:CONTENTS ARE FLAMM. KEEP AWAY FROM
HEAT, SPK & OPEN FLAME. DURING USE & UNTIL ALL VAPS GONE:KEEP AREA
VENT. DO NOT SMOKE. EXTING ALL FLAMES, (SUPDAT)
Other Precautions:INTENTIONAL MISUSE BY DELIB CONC & INHALING CONTENTS
CAN BE HARMFUL/FATAL. THESE PRODS MAY BE MIXED W/OTHER COMPONENTS,
INCL REDUCERS, BEFORE USE. BEFORE OPENING PACKAGES, READ & FOLLOW
WARNING LABELS & MSDS ON ALL COMPONENTS. USE (ING 8)
* Physical/Chemical Properties *
HCC:F4
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BY FIRE:CARBON DIOXIDE, CARBON
MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:WASTE FROM PROD MAY BE HAZ AS DEFINED UNDER RCRA
WASTE NUMBERS. INCIN IN APPRVD FACILITY. DO NOT INCIN CLSD CNTNR.
DISPOSE OF I/A/W FED, STATE, & LOCAL REGS REGARDING POLLUTION.
| 1 | gloves_mandatory |
Control Measures
*
Proprietary Ind: Y
*
Contractor Summary
*
*
Item Description Information
*
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: INHALATION: DUST CAN IRRITATE THE NOSE AND THROAT.
PROLONGED INHALATION OF DUST OR FUMES FROM MOLDING OPERATIONS CAN CAUSE
RESPIRATORY IRRITATION AND SENSITIZATION. EYES: SLIGHTLY IRRITATING TO EYES.
SKIN: REPEATED CONTACT CAN CAUSE AN ALLERGIC REACTION IN SOME INDIVIDUALS.
INGESTION: POSSIBLY HARMFUL (EFTS OF OVEREXP)
Signs And Symptions Of Overexposure: HLTH HAZ: IF SWALLOWED. DELAYED EFFECTS:
REPEATED AND PROLONGED DUST INHALATION CAN CAUSE LUNG INVOLVEMENT SUCH AS
PNEUMOCONIOSIS OR SILICOSIS. CRYSTALLINE SILICA HAS RECENTLY BEEN CLASSIFIED
BY IARC AS A "PROBABLE HUMAN CARCINOGEN" BASED ON ANIMAL AND LIMITED HUMAN
STUDIES.
Medical Cond Aggravated By Exposure: NO INFORMATION.
First Aid: INHAL: MOVE TO FRESH AIR. EYES: FLUSH EYES WITH A LARGE AMOUNT OF
AFFECTED SKIN AREAS WITH SOAP AND WATER. INGESTION: IF SWALLO WED DILUTE BY
GIVING 2 GLASSES OF WATERTO DRINK. SEE MD. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.
*
Handling and Disposal
*
Spill Release Procedures: SCOOP/SHOVEL SOLID MATL INTO SUITABLE CNTNR FOR
RECOVERY/DISP. KEEP DUST TO MIN. FOLLOW PERSONAL PROT EQUIP RECOMS. NOTIFY
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: FOR DISCARD ANTIMONY TRIOXIDE IS A LISTED HAZARDOUS
WASTE. INCINERATE AT A PERMITTED FACILITY IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
Handling And Storage Precautions: NO INFORMATION.
Other Precautions: NO INFORMATION.
*
Fire and Explosion Hazard Information
*
Extinguishing Media: FOAM, CARBON DIOXIDE, WATER SPRAY.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: REMAIN UPWIND. AVOID SMOKE. COMBUSTIBLE AND
TOXIC FUMES OF CARBON OXIDES MAY BE RELEASED AT DECOMPOSITION TEMPERATURE
*
*
Respiratory Protection: NONE REQD IF AIRBORNE CONCS ARE MAINTAINED BLOW
TWA/TLV. FOR DUST/MIST EXPOS UP TO 5X TWA/TLV WEAR NIOSH/MSHA APPRVD (OR
MASKRESP EQUIPPED WITH DUST/MIST (SUPDAT)
Ventilation: LOC EXHST AT POINT OF DUST RELS. REFER TO CURRENT EDITION OF
"INDUS VENT: A MANUAL OF REC PRACTICE" PUBLISHED BY ACGIH.
Other Protective Equipment: LONG SLEEVES; EYEWASH FACILITY. EYEWASH FOUNTAIN &
DELUGE SHOWER MEETING ANSI DESIGN CRITERIA (FP N).
Work Hygienic Practices: GOOD PERSONAL HYGIENE TO BE FOLLOWED AT ALL TIMES.
APPRVD POS-PRESS SCBA OR FULL FACEPIECE SUPPLIED AIR RESP IN POS-PRESS MODE.
*
Physical/Chemical Properties
*
Vapor Pres: SUPDAT
Spec Gravity: 1.0 (H*2O=1)
Solubility in Water: NEGLIGIBLE
Appearance and Odor: BLACK, GRANULAR SOLID; FAINT PHENOLIC ODOR.
*
Reactivity Data
*
Stability Indicator: YES
Hazardous Decomposition Products: COMBUSTIBLE AND TOXIC FUMES OF CARBON OXIDES
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Company Name: BUEHLER LTD.
Label Required IND: Y
Status Code: C
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: INHALATION: DUST CAN IRRITATE THE NOSE AND
THROAT. PROLONGED INHALATION OF DUST OR FUMES FROM MOLDING OPERATIONS CAN
CAUSE RESPIRATORY IRRITATION AND SENSITIZATION. EYES: SLIGHTLY IRRITATING TO
EYES. SKIN: REPEATED CONTACT CAN CAUSEAN ALLERGIC REACTION IN SOME
INDIVIDUALS. INGESTION: POSSIBLY HARMFUL IF SWALLOWED. CHRONIC: CANCER
HAZARD. CONTAINS ANTIMONY OXIDE AND CRYSTALLINE SILICA - CRYS TABOLITE WHICH
ARE LISTED AS LUNG CARCINOGENS (FP N). REPEATED AND PROLONGED DUST INHALATION
CAN CAUSE LUNG INVOLVEMENT SUCH AS PNEUMOCONIOSIS OR SILICOSIS. CAN CAUSE
SKIN AND RESPIRATORY SENSITIZATIO N.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF TLV OF THE PRODUCT OR ANY COMPONENT IS
EXCEEDED A NIOSH/MSHA JOINTLY APPROVED AIR SUPPLIED RESPIRATOR IS
ADVISED IN THE ABSENCE OF PROPER ENVIRONMENTAL CONTROL.
Ventilation:LOCAL EXHAUST AND MECHANICAL (GENERAL):RECOMMENDED.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER .
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING RESTROOM.
SMOKE ONLY IN APPROVED SMOKING AREAS.
Supplemental Safety and Health
EXPLO HAZS:CAUSE A HEALTH HAZARD. SYMPTOMS MAY NOT BE IMMEDIATELY
APPARENT. OBTAIN MEDICAL ATTENTION.
* Product Identification *
CAGE:PETRX
CAGE:PETRX
* Composition/Information on Ingredients *
Ingred Name:STODDARD SOLVENT; (MINERAL SPIRITS)
Ingred Name:AROMATIC HYDROCARBON RESIN
Fraction by Wt: <2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICA GEL; (AMORPHOUS SILICA)
Fraction by Wt: 3-5%
OSHA PEL:6 MG/M3
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION:ANESTHETIC, IRRITATION OF
THE RESPIRATORY TRACT OR ACUTE NERVOUS SYSTEM DEPRESSION
CHARACTERIZED BY THE FOLLOWING STEPS:HEADACHE, DIZZINESS,
STAGGERING GAIT, CONFUSION, UNCONSCIOUSNESS OR C OMA. SKIN OR EYE
CONTACT:PRIMARY IRRITANT.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE RECOGNIZED.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR IMMED, RESTORE BRTHG. IF COUGHING,
DFCLT BRTHG/ANY OTHER RESP SYMPS DEVELOP, SEEK MED ATTN @ ONCE.
SKIN:WASH A FFECTED AREA W/SOAP & WATER. REMOVE CONTAM CLTHG. IF
IRRIT PERSISTS CONSULT MD. INGEST:DRINK 1-2 GLASSES OF WATER TO
DILUTE. DO NOT INDUCE VOMIT. CONSULT MD/POIS CTL CTR IMMED. TREAT
SYMPTOMATICALLY.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:0.9%
Extinguishing Media:"ALCOHOL" FOAM, CO*2, DRY CHEMICAL OR WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT, ELEC EQUIP, SPKS &
OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
DURING EMER CNDTNS OVEREXP TO COMBUST PRODS MAY (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA. AVOID BREATHING OF VAPORS. USE
NIOSH/MSHA APPROVED SELF-CONTAINED BREATHING APPARATUS OR AIRMASK
FOR LARGE SPILLS IN A CONFINED AREA. ELIMINATE IGNITION SOURCES.
REMOVE WITH INERT ABSO RBENT AND NON-SPARKING TOOLS. AVOID CONT
W/EYES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DO NOT BREATHE VAPORS. ALWAYS USE WITH
ADEQUATE VENTILATION. DO NOT TAKE INTERNALLY. DO NOT GET IN EYES,
ON SKIN OR ON CLTHG. WEAR IMPERVIOUS CLTHG.
Other Precautions:KEEP AWAY FROM HEAT AND FLAME. GROUND CONTAINER WHEN
POURING. NEVER USE WELDING OR CUTTING TORCH ON OR NEAR DRUM (EVEN
EMPTY) BECAUSE PRODUCT (EVEN RESIDUE) CAN IGNITE EXPLOSIVELY.
* Physical/Chemical Properties *
Vapor Density:HVR/AIR
Solubility in Water:NIL
Appearance and Odor:AMBER LIQUID/PAINT THINNER ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CONTACT WITH STRONG OXIDIZING AGENT.
Stability Condition to Avoid:CONTACT WITH STRONG OXIDIZING AGENT.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
MONOXIDE AND/OR CARBON DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:CAREFULLY DISPOSE IN CHEMICAL DISPOSAL AREA OR
IN A MANNER THAT COMPLIES WITH LOCAL, STATE AND FEDERAL
REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SCBA OR SUPPLIED AIR RESPIRATORY PROTECTION
REQUIRED FOR ENTRY INTO TANKS, VESSELS, OR OTHER CONFINED SPACES.
Ventilation:ADEQUATE TO MEET PERMISSIBLE CONCENTRATIONS.
Other Protective Equipment:PROTECTIVE CLOTHING SUCH AS UNIFORMS,
COVERALLS OR LAB COATS SHOULD BE WORN.
Work Hygienic Practices:WASH HANDS.SEPERATE WORK CLOTHES FROM STREET
CLOTHES.LAUNDER WORK CLOTHES BEFORE REUSE.KEEP FOOD OUT OF THE WORK
AREA.
Supplemental Safety and Health
NONE
* Product Identification *
Preparer's Name:M.J. VONALLMEN
* Composition/Information on Ingredients *
Ingred Name:BENZENE (SARA III)
Other REC Limits: SPECIFIED
Ingred Name:TOLUENE (SARA III)
Other REC Limits: SPECIFIED
Ingred Name:ETHYL BENZENE (SARA III)
Other REC Limits: SPECIFIED
Ingred Name:XYLENES (O-,M-,P- ISOMERS) (SARA III)
Other REC Limits: SPECIFIED
Ingred Name:1,2,4-TRIMETHYLBENZENE (SARA III)
Other REC Limits: SPECIFIED
Ingred Name:METHYL TERT-BUTYL ETHER (SARA III)
Other REC Limits: SPECIFIED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:GASOLINE
Other REC Limits: RECOMMENDED
Ingred Name:ALIPHATIC PETROLEUM SOLVENT
Other REC Limits: RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:EYES:SLIGHT TO MODERATE
RABBIT>5MG/KG.INHAL:IRRITATES EYES,NOSE,THROAT.CAUSES CNS EFFECTS.
INGEST:MAY CAUSE LUNG DAMAGE IF VOMITTED AFTER
SWALLOWING.CHRONIC-GASOLINE VAPORS MAY CAUSE LIVER AND KIDNEY
DAMAGE.
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:SKIN:REDNESS,EDEMA,DRYING.INHAL:CNS
EFFECTS-DIZZINESS,BLUISH SKIN COLOR.
Medical Cond Aggravated by Exposure: SPECIFIED BY MANUFACTURER.
* First Aid Measures *
CONTAMINATED CLOTHING;WASH EXPOSED AREA WITH SOAP AND WATER.
INGESTION: DO NOT INDUCE VOMITING! CALL A PHYSICIAN. INHALATION:
REMOVE TO FRESH AIR. G IVE ARTIFICIAL RESPIRATION OR OXYGEN
IFNEEDED.CALL PHYSICIAN.
* Fire Fighting Measures *
Flash Point Method:COC
Lower Limits:1.4 %
Upper Limits:7.6 %
Extinguishing Media:DRY CHEMICAL, FOAM, CARBON DIOXIDE.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE ON FLAMES, BUT SHOULD
BE USED TO COOL FIRE-EXPOSED CONTAINERS. USE A SELF-CONTAINED
BRETAHING APPARATUS AND FULL PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND TRAVEL
ALONG THE FLOOR;FLOWING GASOLINE GENERATES STATIC ELECTRICITY
...THIS PRESENTS A FLASHBACK HAZARD.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE IGNITION SOURCES. VENTILATE AREA.
AVOID BREATHING VAPORS. USE SCBA FOR LARGE SPILLS OR IN CONFINED
AREAS. CONTAIN SPILL IF POSSIBLE. REMOVE WITH NON-FLAMMABLE
ADSORBANT(EG.DIATOMACEOUS EARTH );PLACE IN APPROPRIATE CONTAINER
FOR DISPOSAL.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:TRANSPORT, HANDLE AND STORE IN
REGULATIONS.
Other Precautions:DANGER! EXTREMELY FLAMMABLE. HARMFUL OR FATAL IF
SWALLOWED!
* Physical/Chemical Properties *
HCC:F2
Vapor Density:3 - 4.0
Evaporation Rate & Reference:N.D.
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID;LIGHT STRAW TO LIGHT RED;GASOLINE ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:HEAT, SPARKS, FLAME AND OTHER SOURCES OF
IGNITION.
Hazardous Decomposition Products:TOXIC LEVELS OF CARBON MONOXIDE,
CARBON DIOXIDE, IRRITATING ALDEHYDES AND KETONES.
* Disposal Considerations *
Waste Disposal Methods:CONSIDERED RCRA HAZARDOUS WASTE;IT IS
FEDERAL,STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:ORGANIC VAPOR RESPIRATOR W/PARTICULATE FILTER
APPROVED BY NIOSH.
FPM FACE VELOCITY.
Other Protective Equipment:NONE
Work Hygienic Practices:USE ONLY NON-FERROUS TOOLS & WEAR NON-SPARKING
SHOES.
Supplemental Safety and Health
HEALTH HAZARDS CONT'D: MAY CAUSE KIDNEY, LIVER & OTHER SYSTEMIC DAMAGE.
MODERATE LEVELS CAN AFFECT HIGHER BRAIN FUNCTIONS & MENTAL
CAPACITY. INHALATION/INGESTION CAN RESULT IN LEAD POISONING, DAMAGE
R ED BLOOD CELL FORMATION, KIDNEY & NERVOUS SYSTEM.
* Product Identification *
* Composition/Information on Ingredients *
Fraction by Wt: 0.1-1%
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:MANGANESE,
(4-((5-CHLORO-4-METHYL-2-SULFOPHENYL)AZO)-3-HYDROXY-2-NAPHTHALENE-C
ARBOXYLATO (2-))
Fraction by Wt: <0.1%
Ingred Name:CRYSTALLINE-QUARTZ SILICA, SILICA DUST (SUSPECTED HUMAN
Fraction by Wt: 0.1-1%
ACGIH TLV:0.1 MG/CUM RESP DUST
Ingred Name:NAPHTHA (PETROLEUM), HEAVY STRAIGHT RUN NAPHTHA (PETROLEUM)
Ingred Name:STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS
Ingred Name:TRIMETHYL BENZENE
Fraction by Wt: 1-5%
Fraction by Wt: 1-5%
Fraction by Wt: 1-5%
Ingred Name:COLUMBIA CARBON, CARBON BLACK, LAMPBLACK, BLACK PEARLS
Fraction by Wt: <0.1%
Other REC Limits:3.5 MG/CUM (NIOSH)
OSHA PEL:3.5 MG/CUM
ACGIH TLV:3.5 MG/CUM
Ingred Name:RED IRON OXIDE/IRON (III) OXIDE/FERRIC OXIDE/YELLOW FERRIC
OXIDE/YELLOW IRON OXIDE/IRON OXIDE PIGMENT
Fraction by Wt: 1-5%
ACGIH TLV:5 MG/CUM (FE)
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION TO RESPIRATORY
TRACT, CNS DEPRESSION. INGESTION: ASPIRATION OF PRODUCT INTO LUNGS
CAN CAUSE CHEMICAL PNEUMONIA WHICH MAY BE FATAL. EYES: IRRITATION.
CONJUNCTIVAL & CORNEAL INJUR Y MAY RESULT. SKIN: IRRITATION,
DERMATITIS. OVEREXPOSURE TO SOLVENTS: (SEE SUPP)
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:IRRITATION, HEADACHE, NAUSEA, FATIGUE,
UNCONSCIOUSNESS, GI DISTURBANCES, VOMITING, ANOREXIA, CONSTIPATION,
REDNESS, TEARING, BLURRED VISION, DRYING, ULCERATIONS. OVEREXPOSURE
TO SOLVENTS: FATIGUE, SLE EP DISTURBANCES, CONSTIPATION, COLIC,
ANEMIA, NEURITIS, LOSS OF APPETITE, METALLIC TASTE IN MOUTH,
ANXIETY, NAUSEA.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING IF NEEDED.
W/PAPER TOWELS/RAGS. WASH W/MILD SOAP & WARM WATER. INGESTION:
DON'T INDUCE V OMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:SCC
Lower Limits:1
Extinguishing Media:CO2/DRY CHEMICAL.
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. USE WATER
SPRAY TO COOL CONTAINERS. DON'T ENTER AREA W/O PROPER PROTECTIVE
EQUIPMENT, INCLUDING SCBA.
Unusual Fire/Explosion Hazard:AVOID IGNITION SOURCES, FLAME, STATIC
ELECTRICITY, HEAT/ELECTRICAL SPARKS.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE IGNITION SOURCES. ABSORB W/SOLID
ABSORBENT. SHOVEL INTO CONTAINERS. LARGE: WEAR PROTECTIVE
EQUIPMENT.
*Handling and Storage *
Handling and Storage Precautions:SECURE CLOSURES & KEEP CONTAINERS
UPRIGHT TO PREVENT LEAKAGE. STORE IN COOL, WELL VENTILATED AREA
AWAY FROM HEAT & OTHER IGNITION SOURCES.
Other Precautions:AVOID FREE FALL OF LIQUID IN EXCESS OF A FEW INCHES.
DON'T FLAME CUT, BRAZE/WELD. GROUND CONTAINERS WHEN POURING.
* Physical/Chemical Properties *
Vapor Density:3.8-4.9
Solubility in Water:INSOLUBLE
Appearance and Odor:WATER WHITE LIQUID W/CHARACTERISTIC PETROLEUM ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:IGNITION SOURCES, FLAME, STATIC
ELECTRICITY, HEAT/ELECTRICAL SPARKS, EXCESSIVE HEAT.
Hazardous Decomposition Products:CO, NITROGEN OXIDE, LEAD, CHROMIUM
FUMES.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF PERSONAL EXPOSURE CAN'T BE CONTROLLED BELOW
APPLICABLE LIMITS, WEAR A PROPERLY FITTED ORGANIC VAPOR/PARTICULATE
RESPIRATOR/WHEN SANDING/ABRADING DRIED FILM, WEAR A DUST/MIST
RESPIRATOR APPROVED BY NIOSH/MSHA FOR DUST.
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF
EXPOSURE IS MAINTAINED BELOW APPLICABLE EXPOSURE LIMITS.
Other Protective Equipment:PROTECTIVE EQUIPMENT TO MINIMIZE EXPOSURE.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE HAZARD CONT'D: DURING EMERGENCY CONDITIONS OVEREXPOSURE TO
DECOMPOSITION PRODUCTS MAY CAUSE A HEALTH HAZARD. SYMPTOMS MAY NOT
BE IMMEDIATELY APPARENT. PRECAUTIONS CONT'D: AVOID BREATHING VAPOR
& SPRAY MIST. AVOID CONTACT W/SKIN & EYES.
* Product Identification *
* Composition/Information on Ingredients *
MINERAL SPIRITS
Fraction by Wt: 2%
Ingred Name:PROPYLENEGLYCOL MONOMETHYL ETHER ACETATE,
1-METHOXY-2-PROPANOL ACETATE
Fraction by Wt: 1%
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE
Fraction by Wt: 6%
OSHA PEL:2 MG/CUM (RESP DUST)
ACGIH TLV:2 MG/CUM (RESP DUST)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF EYES, SKIN & RESPIRATORY
SYSTEM, MAY CAUSE NERVOUS SYSTEM DEPRESSION, BURNING & DEATH.
PROLONGED OVEREXPOSURE TO SOLVENT MAY CAUSE ADVERSE EFFECTS TO THE
LIVER, URINARY, BLOOD FORMING & REPRODUCTIVE SYSTEMS.
REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, UNCONSCIOUSNESS, HEADACHE,
DIZZINESS, NAUSEA, LOSS OF COORDINATION, REDNESS, ITCHING, BURNING
SENSATION.
Medical Cond Aggravated by Exposure:NONE
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. KEEP WARM
& QUIET. SKIN: WASH AREA THOROUGHLY W/SOAP & WATER. EYES: FLUSH
ALL CASE S.
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:0.9
Extinguishing Media:CO2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIPMENT & SCBA. WATER
SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE. WATER MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:COMBUSTIBLE. CLOSED CONTAINERS MAY
EXPLODE WHEN EXPOSED TO EXTREME HEAT. APPLICATION TO HOT SURFACES
REQUIRES SPECIAL PRECAUTIONS. (SEE SUPP)
* Accidental Release Measures *
Spill Release Procedures:REMOVE SOURCES OF IGNITION. VENTILATE & REMOVE
W/INERT ABSORBENT.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT/OPEN FLAME. KEEP
CONTAINER CLOSED WHEN NOT IN USE. TRANSFER TO APPROVED CONTAINERS &
LABELING. USE ONLY W/ADEQUATE VENTILATION.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. DON'T TAKE INTERNALLY.
USE APPROVED BONDING & GROUNDING PROCEDURES. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING & INHALING THE CONTENTS CAN BE
HARMFUL/FATAL. CONTEN TS ARE COMBUSTIBLE. (SEE SUPP)
* Physical/Chemical Properties *
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, OPEN FLAME & SOURCES OF IGNITION,
HOT SURFACES.
Hazardous Decomposition Products:BY FIRE: CO2, CO
* Disposal Considerations *
Waste Disposal Methods:WASTE FROM PRODUCT MAY BE HAZARDOUS UNDER THE
RCRA & MUST BE TESTED FOR IGNITABILITY. DISPOSE/INCINERATE IN
APPROVED FACILITY IAW/FEDERAL, STATE & LOCAL REGULATIONS. DON'T
INCINERATE CLOSED CONTAINER.
| 1 | gloves_mandatory |
Control Measures
*
Product ID: COMPUBLEND (TM) II BASE W
*
Contractor Summary
*
*
Item Description Information
*
Item Manager: GSA
Item Name: CLEANING COMPOUND,SOLVENT-DETERGENT
Unit of Issue: BX
UI Container Qty: 1
*
Ingredients
*
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
-----------------------------
% Wt: 0.5-1.5
Other REC Limits: NONE RECOMMENDED
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYE: IRRITATION (REDNESS, SWELLING, PAIN, TEARING, HAZY
VISION). SKIN: IRRITATION (REDNESS, SWELLING, ITCHING). INGESTION: IRRITATION
OF GASTROINTESTINAL TISSUES (PAIN, VOMITING, ABDOMINAL TENDERNESS, NAUSEA,
BLOOD IN VOMITUS, AND BLOOD INFECES. INHAL: UPPER RESP IRRIT (NOSE/THROAT
SORENESS/COUGHING/SNEEZING)
First Aid: EYE: IMMED FLUSH W/LOTS WATER. GET IMMED MED AID. SKIN: IMMED FLUSH
W/LOTS WATER. IF IRRITATION PERSISTS, GET MED AID. INHALATION: REMOVE TO
FRESH AIR. IF SYMPTOMS CONTINUE, CALL DR. INGEST: DON'T IND UCE VOMITING.
DRINK 2 GLASSES OF WATER.CALL DR.
*
Handling and Disposal
*
Spill Release Procedures: VENTILATE AREA. DIKE/COVER W/ABSORBENT MATERIAL.
COLLECT SPILL. CLEAN UP RESIDUE W/WATER. PLACE IN CLOSED CONTAINER.
Waste Disposal Methods: <5 GAL: WASTEWATER TREATMNT SYS. REDUCE DISCHARGE
RATE IF FOAMING. INCINERATE IN HZD WASTE INCINERATOR IN PRESENCE OF
COMBUSTIBLE MAT'L.
Handling And Storage Precautions: DO NOT INGEST. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions: KEEP CONTAINER CLOSED WHEN NOT IN USE. KEEP OUT OF REACH OF
CHILDREN.
*
Fire and Explosion Hazard Information
*
Flash Point Method: TCC
Flash Point Text: NA
Lower Limits: NA
Upper Limits: NA
Extinguishing Media: WATER, CARBON DIOXIDE, DRY CHEMICAL, FOAM
Fire Fighting Procedures: NA
Unusual Fire/Explosion Hazard: NA
*
*
Respiratory Protection: NA
Ventilation: NA
*
Physical/Chemical Properties
*
M.P/F.P Text: NA
Vapor Pres: NE
Vapor Density: NE
Spec Gravity: CA 1.0(WATER=1)
PH: 6-8
Evaporation Rate & Reference: NE
Solubility in Water: COMPLETE
Appearance and Odor: LIQUID, CLEAR, COLORLESS TO LIGHT AMBER COLOR, MILD ODOR
*
Reactivity Data
*
Stability Indicator: YES
Materials To Avoid: NA
Hazardous Decomposition Products: CARBON MONOXIDE AND CARBON DIOXIDE
Hazardous Polymerization Indicator: NO
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
Transportation Information
*
Product ID: COMPUBLEND (TM) II BASE W
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: BX
Container QTY: 1
*
Detail DOT Information
*
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail IMO Information
*
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
*
Detail IATA Information
*
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail AFI Information
*
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
HAZCOM Label
*
Product ID: COMPUBLEND (TM) II BASE W
Company Name: MINNESOTA MINING AND MFG CO ENGINEERING DOCUMENT SYSTEMS DIV
Street: 3M CTR
Label Required IND: Y
Status Code: A
Origination Code: G
Hazard And Precautions: EYE: IRRITATION (REDNESS, SWELLING, PAIN, TEARING, HAZY
VISION). SKIN: IRRITATION (REDNESS, SWELLING, ITCHING). INGESTION: IRRITATION
OF GASTROINTESTINAL TISSUES (PAIN, VOMITING, ABDOMINAL TENDERNESS, NAUSEA,
BLOOD IN VOMITUS, AND BLOOD INFECES. INHAL: UPPER RESP IRRIT (NOSE/THROAT
SORENESS/COUGHING/SNEEZING)
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:AVOID INHALATION. USE NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
WASTE DISP METH: SHAKING AND TAPPING SIDES AND BOTTOM TO LOOSEN
CLINGING PARTICLES. EMPTY RESIDUE INTO APPLICATION EQUIP. DISPOSE
OF CONTAINER IN SANITARY LANDFILL OR BY OTHER APPROVED FEDERAL,
STATE, AND LOCAL PROCEDURES. OTHER PREC: OF WASTE. STORE UPRIGHT
AT ROOM TEMPERATURES. AVOID EXPOS TO MOISTURE.
* Product Identification *
Preparer's Name:DIRECTOR OF MANUFACTURING
* Composition/Information on Ingredients *
Ingred Name:PYRETHRUM
Fraction by Wt: 1%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TOLUENE, ALPHA-(2-(2-BUTOXYETHOXY) ETHOXY)-4,5-
(METHYLENEDIOXY)-2-PROPYL- (PIPERONYL BUTOXIDE)
Ingred Name:SILICA GEL (AMORPHOUS-SYNTHETIC)
OSHA PEL:6 MG/M3
Ingred Name:INSOPARAFFINIC PETROLEUM SOLVENT
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: MILD TO NON-IRRITATING. SKIN:
NON-IRRITATING.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INGEST: CONTACT A PHYSICIAN OR POISON CONTROL CENTER IMMED.
DO NOT INDUCE VOMITING UNLESS DIRECTED BY A PHYS. INHAL: REMOVE
AFFECTED PERSON TO FRESH AIR. APPLY ARTIFICIAL RESPIRATION IF
INDICATED. EYE S: FLUSH WITH PLENTY OF WATER, CONTACT A PHYSICIAN
IF IRRITATION PERSISTS. SKIN: REMOVE CONTAMINATED CLOTHING AND WASH
AFFECTED AREAS OF SKIN WITH SOAP AND WATER. CONTACT PHYSICIAN IF
IRRIT PERSISTS.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL, & WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . COOL FIRE EXPOSED AREAS & EQUIPMENT.
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:IN CASE OF SPILL OR LEAKAGE, SWEEP UP AND
DISCARD WITH CHEMICAL WASTE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:CONTRS LRGR THAN ONE POUND MAY NOT BE
USED/STORED IN FOOD HANDLING ESTABLISHMENTS. PROD IS TOXIC TO FISH.
Other Precautions:DON'T APPLY DIRECTLY TO LAKES, STREAMS, PONDS, TIDAL
MARSHES/ESTUARIES. DON'T APPLY WHERE RUNOFF IS LIKELY TO OCCUR.
DON'T APPLY WHEN WEATHER CONDITIONS FAVOR DRIFT FROM AREAS TREATED.
DO NOT CONTAM H *2O BY CLEANING OF EQUIP/DISP(SUPP DATA)
* Physical/Chemical Properties *
HCC:V4
Solubility in Water:INSOLUBLE
Appearance and Odor:AMORPHOUS OFF-WHITE POWDER, SLIGHT ODOR.
* Stability and Reactivity Data *
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:DO NOT CONTAM H*2O, FOOD/FEED BY STOR/DISP.
PESTICIDE DISP: PESTICIDES, SPRAY MIX/RINSE H*2O THAT CANNOT BE
USED ACCORDING TO LBL INSTRUCTIONS MUST BE DISP OF AT/BY APPRVD
WASTE DISP FACILITY. CONTR D ISP: COMPLETELY EMPTY LINER BY (SEE
SUPP DATA)
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR
Ventilation:MECHANICAL EXHAUST
Other Protective Equipment:SAFETY SHOWER, EYEBATH, RUBBER BOOTS & HEAVY
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:PUTRESCINE DIHYDROCHLORIDE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE HARMFUL BY INHALATION,
INGESTION/SKIN ABSORPTION. CAUSES SKIN & EYE IRRITATION. IRRITATING
TO MUCOUS MEMBRANES & UPPER RESPIRATORY TRACT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
* First Aid Measures *
WASH W/SOAP & COPIOUS AMOUNTS OF WATER. INHALATIONS: REMOVE TO
FRESH AIR. IF NOT BREATHING GIVE CPR. IF BREATHING IS DIFFICULT
GIVE OXYGEN. IN GESTION: WASH OUT MOUTH W/WATER IF CONSCIOUS.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, CO2, DRY CHEMICAL POWDER/APPROPRIATE
FOAM
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING INCLUDING SCBA.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES.
* Accidental Release Measures *
Spill Release Procedures:WEAR FULL PROTECTIVE GEAR. SWEEP UP, PLACE IN
BAG & HOLD FOR DISPOSAL. AVOID RAISING DUST. VENTILATE & WASH SITE
AFTER PICKUP.
*Handling and Storage *
Handling and Storage Precautions:KEEP TIGHTLY CLOSED. STORE IN A COOL
DRY PLACE.
* Physical/Chemical Properties *
Appearance and Odor:WHITE POWDER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:TOXIC FUMES OF: CO, CO2, NITROGEN
OXIDES, HYDROGEN CHLORIDE GAS
* Disposal Considerations *
Waste Disposal Methods:DISSOLVE/MIX W/COMBUSTIBLE SOLVENT & BURN IN A
CHEMICAL INCINERATOR EQUIPPED W/AN AFTERBURNER & SCRUBBER. DISPOSE
OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
NECESSARY.
Ventilation:USE EXPLO-PROOF VENT EQUIP. USE ADEQ GENERAL OR LOC EXHST
VENT TO KEEP AIRBORNE CONCS BELOW PERMISSIBLE EXPOS LIMITS.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
WEAR IMPERVIOUS APRON. WEAR APPROP PROT CLTHG TO PREVENT SKIN
EXPOSURE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
IN HEAT OF FIRE. EFTS OF OVEREXP: MUSC WEAK & DMG, MOTOR INCOORD &
SENSATION DISTURBS. TARGET ORGANS:HEART, NERVOUS SYS. FIRST AID
PROC: ASPIR HAZ. GET MED AID IMMED. INHAL:REMOVE FROM EXPOS TO
FRESH AIR IMMED. IF NOT BRTHG, GIVE ARTF RESP. (ING 4)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:3-METHYL PENTANE
Fraction by Wt: 4.2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CYCLOPENTANE, METHYL-; (METHYLCYCLOPENTANE)
Fraction by Wt: 9.7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:HEXANE (CERCLA)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SUPDAT: IF BREATHING IS DFCLT, GIVE OXYGEN. GET MED AID.
NOTE TO MD: TREAT SYMPTOMATICALLY & SUPPORTIVELY.
Ingred Name:OTHER PRECS: VAPOR), & CAN BE DANGEROUS. AVOID CONTACT
W/HEAT, SPARKS & FLAME. DO NOT GET ON SKIN OR IN EYES. DO (ING 6)
Ingred Name:ING 5: NOT INGEST OR INHALE. DO NOT PRESSURIZE, CUT, WELD,
BRAZE, SOLDER, DRILL, GRIND OR EXPOSE EMPTY CNTNRS (ING 7)
Ingred Name:ING 6: TO HEAT, SPARKS OR OPEN FLAMES.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:CNTCT PRDCES IRRIT, TEARING &
BURNING PAIN. SKIN:MAY BE ABSORBED THRU SKIN IN HARMFUL AMTS. MAY
BE ABSORBED THRU SKIN. CAUSES IRRIT W/BURNING PAIN, ITCH & REDNESS.
INGEST:ASPIR HAZ. MAY CAUSE GI I RRIT W/NAUS, VOMIT & DIARR. MAY
CAUSE EFTS SIMILAR TO INHAL EXPOS. ASPIR CAN CAUSE ASPHY, BRAIN DMG
& (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: CARD ARREST. EXPOS MAY CAUSE CARD
SENSIT. INHAL: EXPOS PRDCES CNS DEPRESS. MAY CAUSE DIZZ,
HALLUCINATIONS, MUSC WEAK, VISUAL DISTURBS & NERVOUS SYS DISTURBS.
CHRONIC: PRLNGD/RPTD EXPOS MAY C AUSE ADVERSE REPRO EFTS. CHRONIC
EXPOS MAY CAUSE VISUAL DISTURBS. RPTD EXPOS MAY CAUSE NERVOUS SYS
ABNORMS WITH (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
OCCASNLY LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. DO NOT
ALLOW VICTIM TO RUB OR KEEP EYES CLOSED. SKIN: GET MED AID IF IRRIT
DEVELOPS/PERS ISTS. RINSE AREA W/LARGE AMTS OF WATER FOR AT LEAST
IF VICTIM IS CONSCIOUS & ALERT, GIVE 2-4 CUPFULS OF MILK OR WATER.
POSS (SUPDAT)
* Fire Fighting Measures *
Lower Limits:1.2%
Upper Limits:7.7%
Extinguishing Media:FOR SM FIRES, USE WATER SPRAY, DRY CHEM, CARBON
DIOXIDE OR CHEM FOAM. USE WATER SPRAY TO COOL FIRE-EXPOSED CNTNRS.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPORS CAN TRAVEL TO SOURCE OF IGNIT &
FLASH BACK. EXTREMELY FLAMMABLE. MATL WILL READILY IGNITE AT ROOM
TEMP. USE WATER SPRAY TO KEEP FIRE-EXPOSED (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:WEAR NIOSH APPRVD SCBA & APPROP PERSONAL PROT.
SCOOP UP W/A NONSPARKING TOOL, THEN PLACE INTO SUITABLE CONTAINER
FOR DISPOSAL. REMOVE ALL SOURCES OF IGNITION. ABSORB SPILL USING AN
ABSORBENT, NON-COMB USTIBLE MATL SUCH AS EARTH, SAND OR
VERMICULITE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM SOURCES OF IGNITION.
STORE IN A COOL, DRY, WELL-VENTILATED AREA AWAY FROM INCOMPATIBLE
SUBSTANCES.
Other Precautions:WASH THOROUGHLY AFTER HNDLG. REMOVE CONTAM CLTHG &
WASH BEFORE REUSE. USE ONLY IN A WELL VENTD AREA. GROUND & BOND
CNTNRS WHEN TRANSFERRING MATL. USE SPARK-PROOF TOOLS & EXPLO PROOF
EQUIP. EMPTY CNTNR S RETAIN PROD RESIDUE (LIQ &/OR (ING 5)
* Physical/Chemical Properties *
Vapor Pres:SUPDAT
Vapor Density:3
Evaporation Rate & Reference:0.3 (N-BUTYL ACETATE=1)
Appearance and Odor:LIQUID; MILD GASOLINE TYPE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXYGEN AND STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:INCOMPATIBLE MATERIALS, IGNITION SOURCES,
EXCESS HEAT.
Hazardous Decomposition Products:OXIDES OF CARBON.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE AND LOCAL REGULATIONS. NOT LISTED AS A MATERIAL BANNED FROM
LAND DISPOSAL ACCORDING TO RCRA.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE A NIOSH APPROVED RESPIRABLE FUME RESPIRATOR
WHEN WELDING IN CONFINED SPACES & WHENEVER FUME CONCENTRATIONS
EXCEED APPLICABLE LIMITS FOR TUNGSTEN OR OTHER WELDING FUMES. ALL
Ventilation:GEN &/OR LOC EXHST AT WELDING ARC REC. IS SUCH EQUIP IS NOT
AVAIL, USE NIOSH APPRVD RESP AS SPECIFIED. AIR (SUPP DATA)
Other Protective Equipment:ANSI APPRVD EYE WASH FOUNTAIN & DELUGE
SHOWER . FOOTWEAR:SUITABLE FOR METAL WORKING. CLOTHING: DARK, (SUPP
DATA)
Work Hygienic Practices:OPERATOR TRAINED TO AVOID ELECTRICAL SHOCK & UV
RAY EXPOSURE.
Supplemental Safety and Health
WELDED. SOME LOSS OF ELECTRODE WILL OCCUR. VENT:SAMPLING IF NEC TO
DETERMINE CORRECTIVE MEASURES. EYE PROT:FULL LGTH FSHLD OR
WELDER'S HELMET W/PROPER FILTER LENS. OTHER PROT
* Product Identification *
Preparer's Name:DENNIS WILSON
* Composition/Information on Ingredients *
Ingred Name:TUNGSTEN
OSHA PEL:N/K
ACGIH TLV:1 MG/M3;3 STEL
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION OF FUMES GENERATED DURING
WELDING. MOST STUDIES FOUND TUNGSTEN TO BE TOXICOLOGICALLY INERT.
SIGNS AND SYMPTOMS OF EXPOSURE: BREATHING DIFFICULTY, HEADACHE,
NAUSEA, DRYNESS OR IRRITATION OF NOSE, THROAT, EYES. BURNING
SENSATION OF SKIN OR EYES. UNCONSCIOUSNESS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:RESPIRATORY PROBLEMS, ERYTHMAS.
* First Aid Measures *
First Aid:INGEST:CALL MD IMMEDIATELY . EYES:IMMEDIATELY FLUSH W/POTABLE
INHAL:REMOVE TO FRESH AIR. IF BREATHING IMPAIRED, ASSISTED RESPIR
ATION MAY BE REQUIRED. SKIN:TREAT U.V. EXPOSURE SIMILAR TO SEVERE
SUNBURN, SEEK MEDICAL ATTENTION!
* Fire Fighting Measures *
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE . NOT
FLAMMABLE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:WELDING ARC & SPARKS CAN IGNITE
CUTTING", PUBLISHED BY THE AMERICAN WELDING SOCIETY.
* Accidental Release Measures *
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Other Precautions:NONE.
* Physical/Chemical Properties *
Boiling Pt:B.P. Text:SUPP DATA
Solubility in Water:NOT SOLUBLE
Appearance and Odor:SOLID, GRAY METAL CYLINDER; NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Hazardous Decomposition Products:WELDING FUMES (OXIDES OF METAL BEING
WELDED & GASES, SUCH AS CARBON MONOXIDE, OZONE & OXIDES OF
NITROGEN) (SUPP DATA)
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT REQUIRED.
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:NOT REQUIRED.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SUBSTRATE CONSISTING OF INGREDIENT 2.
OSHA PEL:SEE INGRED NAME
Ingred Name:COATING LAYER (ARSENIC-SELENIUM ALLOY) CONSISTING OF
INGREDIENT 4.
Fraction by Wt: < 2%
Ingred Name:ARSENIC TRISELENIDE (SARA III)
OSHA PEL:0.1 MG(AS)/M3
ACGIH TLV:0.2 MG(AS)/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:RISKS IN THE CONDITIONS OF ARSENIC
TRISELENIDE ARE UNKNOWN. NO MUTAGENICITY DETECTED IN AMES ASSAY.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SINCE ARSENIC TRISELENIDE IS INSOLUBLE IN THE
BODY, IT CANNOT BE DECOMPOSED INTO ITS ELEMENTS ARSENIC & SELENIDE.
Medical Cond Aggravated by Exposure:UNKNOWN.
* First Aid Measures *
First Aid:SKIN:FLUSHING OF AFFECTED ARE WITH WATER OR SODIUM
THIOSULFATE OINTMENT. EYE: IMMED FLUSH WITH POTABLE WATER FOR A
AIR. SUPPOR T BREATHING (GIVE O2/ARTF RESP) .INGEST: GET MD
IMMEDIATELY .
* Fire Fighting Measures *
Extinguishing Media:DRY CHEMICAL
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NOTHING.
* Accidental Release Measures *
Spill Release Procedures:USUAL CLEANING METHOD.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:NONE
Other Precautions:NONE
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DARK SILVER, COATED METAL CYLINDER, ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACID AND ALKALI
Stability Condition to Avoid:
Hazardous Decomposition Products:AS2O3, OXIDE OF SELENIUM ALLOY.
* Disposal Considerations *
Waste Disposal Methods:RETURN USED DRUM TO THE SUPPLIER FOR PROPER
DISPOSAL BY AUTHORIZED DISPOSAL AGENCY.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:WEAR SUITABLE PROTECTIVE CLOTHING. SAFETY
SHOWER & EYE BATH.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:TITANIUM (IV) ETHOXIDE, TECH
Ingred Name:ETHYL ALCOHOL
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: NERVES & LIVER. ACUTE:
MAY BE HARMFUL BY INHALATION, INGESTION OR SKIN ABSORPTION. VAPOR
OR MIST IS IRRITATING TO EYES, MUCOUS MEMBRANES & UPPER RESPIRATORY
TRACT. CAUSES SKIN IRRITATIO N.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:EYES:IMMEDIATELY FLUSH W/COPIOUS AMOUNTS OF WATER FOR AT
WATER. WASH CONTAMINATED CLOTHING BEFORE REUSE. INHAL:REMOVE TO
FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. INGEST:WASH OUT MOUTH W/WATER
PROVIDED PERSON IS CONSCIOUS. CALL MD.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL POWDER OR
APPROPRIATE FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . PREVENT CONTACT W/SKIN & EYES. FLAMMABLE
LIQUID.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
VAPOR MAY TRAVEL CONSIDERABLE DISTANCE TO SOURCE OF IGNITION &
FLASH BACK.
* Accidental Release Measures *
Spill Release Procedures:WEAR NIOSH/MSHA APPROVED SCBA, RUBBER BOOTS &
A CLOSED CONTAINER & HOLD FOR WASTE DISPOSAL. VENTILATE AREA & WASH
SPILL SITE AFTER M ATERIAL PICKUP IS COMPLETE.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP AWAY
FROM HEAT, SPARKS, OPEN FLAME & SOURCES OF IGNITION. MOISTURE
SENSITIVE. KEEP TIGHTLY CLOSED.
Other Precautions:IRRITANT. AVOID INHALATION. DO NOT GET IN EYES, ON
SKIN OR ON CLOTHING. NO SMOKING.
* Physical/Chemical Properties *
Appearance and Odor:VISCOUS COLORLESS LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS & STRONG ACIDS.
Stability Condition to Avoid:MAY DECOMPOSE ON EXPOSURE TO MOIST AIR OR
WATER.
Hazardous Decomposition Products:TOXIC FUMES OF CARBON MONOXIDE, CARBON
DIOXIDE & TITANIUM/TITANIUM OXIDES.
* Disposal Considerations *
Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED W/AN
AFTERBURNER & SCRUBBER BUT EXERT EXTRA CARE IN IGNITING AS THIS
MATERIAL IS HIGHLY FLAMMABLE. DISPOSAL MUST BE IN ACCORDANCE
W/FEDERAL, STATE & LOCAL REGUL ATIONS .
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NOISH APPROVED AIR-PURIFYING RESPIRATORS OR
NOISH APPROVED SUPPLIED AIR RESPIRATORS FOR ORGANIC VAPORS IN
PPM. DO NOT ATOMIZE SPRAY.
Other Protective Equipment:FULL CHEMICAL SUIT, CHEMICAL BOOTS, APRON AS
NECESSARY.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:METHYLENE CHLORIDE(SARA III)
Other REC Limits:NONE SPECIFIED
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES
Health Hazards Acute and Chronic:INHALATION: CENTRAL NERVOUS SYSTEM
DEPRESSION, ELEVATED CARBOXYHEMOGLOBIN LEVELS MAY CONTRIBUTE TO
STRESS ON THE CARDIOVASCULAR SYSTEM. LIVER, KIDNEY DAMAGE. SKIN AND
EYES: IRRITATION. MAY CAUSE ABSOR PTION THROUGH THE SKIN.
Explanation of Carcinogenicity:DICHLOROMETHANE: NTP: (ANIMAL
CARCINOGEN), IARC: (LIMITED EVIDENCE ANIMAL CARCINOGEN.
Effects of Overexposure:DIZZINESS, HEADACHE, NAUSEA, DEFATTING OF SKIN,
DERMITITIS.
* First Aid Measures *
First Aid:INGESTION: DO NOT INDUCE VOMITING. EYE CONTACT: FLUSH WITH
ARTIFICIAL RESPIRATION IF NECESSARY. GET MEDICAL ATTENTION FOR ANY
OF THE A BOVE CONDITIONS. DERMAL: FLUSH WITH SOAP AND WATER.
* Fire Fighting Measures *
Flash Point Method:COC
Flash Point:NONE
Extinguishing Media:CARBON DIOXIDE, FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:FULL FIREFIGHTING EQUIPMENT.
Unusual Fire/Explosion Hazard:TOXIC AND ACIDIC VAPORS.
* Accidental Release Measures *
Spill Release Procedures:SWEEP OR SCOOP UP AND REMOVE, USE INDUSTRIAL
VACUUM. AVOID OPEN FLAMES, CONTACT WITH SKIN AND EYES, AND
BREATHING VAPORS.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP DRUM CLOSED WHEN NOT IN USE.
* Physical/Chemical Properties *
Spec Gravity:1.2
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:PARTIAL
Appearance and Odor:LIQUID,SOLVENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, STRONG ALKALIES, STRONG ACIDS.
Hazardous Decomposition Products:HYDROGEN CHLORIDE, PHOSGENE (SMALL
AMOUNTS). CAN RELEASE HYDROGEN SULFIDE AND SULFER OXIDES.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE MSHA/NIOSH APPROVED UNITS. USE UNITS PER
INSTRUCTIONS & WARNINGS. AIR PURIFYING OV/FILTER UNITS MAY BE
ACCEPTABLE.
Ventilation:LOCAL AND MECHANICAL EXHAUST.
Other Protective Equipment:EYE BATH AND SAFETY SHOWER.
Work Hygienic Practices:MAINTAIN GOOD PERSON HYGIENE. DO NOT USE IN
CONFINED AREAS WITHOUT ADEQUATE VENTILATION.
Supplemental Safety and Health
NK
* Product Identification *
Preparer's Name:ROBERT COMMISSO
* Composition/Information on Ingredients *
Fraction by Wt: NA
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: 7.0%
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: DROWSINESS, DIZZINESS, FATIGUE,
COMA, LUNG CHANGES, NAUSEA, VOMITING, COUGH, PULMONARY IRRITATION,
CNS DEPRESSION. EYE: IRRITATION. SKIN: IRRITATION &/OR DERMITITIS,
ABSORPTION (IRRITATION, DEF ATTING & DERMITITIS). INGEST:
PNEUMONITIS, PULMONARY EDEMA, HEMORRAGE, GI DISTURBANCE.
Medical Cond Aggravated by Exposure:DISEASES OF SKIN, CENTRAL NERVOUS
SYSTEM, LIVER AND KIDNEYS.
* First Aid Measures *
SEEK MED AID. SKIN: WASH THOROUGHLY W/SOAP & WATER. SEEK MED AID.
INGEST: IMMEDIATELY SEEK MED AID. DONT INDUCE VOMITING. DONT GIVE
ANYTHI NG BY MOUTH TO UNCONSCIOUS PERSON.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1.0
Upper Limits:NA
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:APPROVED GAS MASK REQUIRED FOR FIRE FIGHTING
PERSONNEL. WATER MAY BE INEFFECTIVE, MAY BE USED TO COOL
CONTAINERS. IF WATER IS USED, FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM IGNITION SOUCES. CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO
HEAT.
* Accidental Release Measures *
Spill Release Procedures:STOP LEAK IF NO RISK INVOLVED. REMOVE ALL
SOURCES OF IGNITION. STAY UPWIND. ABSORB WITH INERT MATERIAL. FLUSH
HAS BEEN DECLARED SAFE.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINERS CLOSED & UPRIGHT TO
PREVENT LEAKAGE. AVOID IGNITION SOURCES.
Other Precautions:MAINTAIN GOOD PERSONAL HYGIENE. DO NOT USE IN
CONFINED AREAS, TAS OR PITS WITHOUT ADEQUATE VENTILATION.
* Physical/Chemical Properties *
Decomp Temp:Decomp Text:NA
Vapor Density:>AIR
Spec Gravity:0.9
pH:NA
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:ESSENTIALLY NIL
Appearance and Odor:VISCOUS LIQUID WITH STRONG SOLVENT ODOR
Corrosion Rate:NA
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:IGNITION SOURCES.
Hazardous Decomposition Products:CO & CO2.
* Disposal Considerations *
Waste Disposal Methods:USE INERT ABSORBENT MATERIAL ON SPILLS. DISPOSE
IN ACCORDANCE WITH ALL FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATORY PROTECTION IN
ABSENCE OF PROPER ENVIRONMENTAL CONTROL. FOR EMERGENCIES, A
NIOSH/MSHA APPROVED SELF CONTAINED BREATHING APPARATUS OR A
NIOSH/MSHA APPROVED FULL FACE RESP IRATOR IS RECOMMENDED.
Ventilation:SUFFICIENT TO PREVENT VAPOR CONTACT. RECOMMEND CONTROL OF
VAPORS TO SUGGESTED GUIDE. LOCAL EXHAUST.
Other Protective Equipment:EYE FOUNTAIN AND SAFETY SHOWER. CLEAN,
BODY-COVERING CLOTHING, BOOTS, AND APRON.
Work Hygienic Practices:USE GOOD INDUSTRIAL HYGIENE.
Supplemental Safety and Health
FIRST AID PROC: TO MED FACILITY. DESTROY CONTAMD SHOES. WASH CLTHG
BEFORE REUSE. INHAL: REMOVE TO FRESH AIR IF EFTS OCCUR. CALL PHYS
&/OR TRANSPORT TO MED FACILITY. ADMIN OXYGEN IF AVAIL. BRONCHODIALA
TORS, EXPECTORANTS, & ANTITUSSIVES MAY BE OF HELP. INGEST: MOD TOX.
MAY CAUSE BURN OF MUC MEMBS. IF LAVAGE IS (ING 3)
* Product Identification *
Preparer's Name:GEORGE C. KARPIN
INC.
* Composition/Information on Ingredients *
Ingred Name:SUPP DATA:PERFORMED, SUGGEST ENDOTRACHEAL &/OR
ESOPHAGOSCOPIC CNTRL. RECOM TO PHYS: SYS: CONSULT STD LITERATURE.
(ING 4)
Ingred Name:ING 3: NO SPECIFIC ANTIDOTE. TREATMENT BASED ON SOUND
JUDGMENT AND INDIVIDUAL REACTIONS OF PATIENT.
Ingred Name:DIETHYLENE TRIAMINE
OSHA PEL:1 PPM
ACGIH TLV:1 PPM, S
Ingred Name:ANILINE, 4,4'-METHYLENEDI-; (4,4'-METHYLENEDIANILINE) (MDA)
ACGIH TLV:0.1 PPM, S
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:MAY CAUSE ALLERGENIC
ASTHMA.MAY CAUSE SEV IRRIT.MAY CAUSE RESP SENSIT/ASTHMA. INGEST:LOW
SINGLE DOSE ORAL TOX;INGEST MAY CAUSE BURNS OF MOUTH, ESOPHAGUS &
POSS STOM.MAY CAUSE BURNS OF MUC MEMB.EYE:MAY CAUSE SERIOUS BURN
W/POSS LOSS OF VISION.MAY CAUSE SEV CORNEAL INJ/BURN. SKIN: BRIEF
CONT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:METHYLENE DIANILINE (4,4): GROUP 2B
(IARC), ANTICIPATED TO BE A CARCINOGEN (NTP).
Effects of Overexposure:HLTH HAZ:(3-5 MINS) MAY CAUSE SERIOUS BURN.
MATL MAY CAUSE SIGNIFICANT SENSIT/ALLERGENIC RESPONSE. SKIN ABSORP:
MAY BE ABSORB IN MOD TOX AMTS. CHRONIC: HUMAN LIVER TOX. FEVER,
CHILLS, ANOREXIA (ANXIET Y) & VOMIT. TOX HEPATITIS, JAUNDICE,
HEPATOTOXIN EFTS. PRODCES ANEMIA & LIVER, THYROID & KIDNEY TOX IN
LAB TEST ANIMALS.
Medical Cond Aggravated by Exposure:EXISTING LIVER DISORDERS MAY BE
AGGRAVATED BY PRODUCT. ALSO EXISTING LUNG DISORDERS. IRRITATION OF
EYES, NOSE, THROAT AND LUNGS. MAY CAUSE SENSITIZATION BY LIQUID OR
VAPORS.
* First Aid Measures *
First Aid:EYE:IMMED & CONTINUOUS IRRIGATION W/FLOWING WATER FOR AT LST
STAIN FOR EVIDENCE OF CORNEAL INJ. IF CORNEA IS BURNED, INSTILL
ANTIBIOTICSTEROID PREPARATION FREQUENTLY. CONSULTOPHTHALMOLOGIST.
IS INDICATED. REMOVE CONTAMD CLTHG IMMED. CALL PHYS &/OR TRANSPORT
(SUPDAT)
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:CONSULT SPECIAL HANDLING INFO FOR PROPER
PROTECTIVE EQUIPMENT. LARGE SPILL-DIKE UP AND DILUTE WITH COPIOUS
QUANTITIES OF WATER. PUMP INTO APPROPRIATE CONTAINERS. SMALL
SPILL-SOAK UP MATERIAL WITH ABSO RBENT MATL; SHOVEL INTO APPROP
CONTAINERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:MATERIAL SHOULD NOT COME IN CONTACT
WITH COPPER OR COPPER BEARING ALLOYS.
Other Precautions:NONE. MATERIAL MAY PRESENT A DUST HAZARD IF CUT,
GROUND, OR MACHINED AFTER CURING.
* Physical/Chemical Properties *
HCC:C2
Solubility in Water:SLIGHT
Appearance and Odor:DARK BROWN LIQUID, AMINE ODOR.
Percent Volatiles by Volume:NIL
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACID, OXIDIZING MATERIAL, CHLORINATED ORGANIC COMPOUNDS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NITROGEN OXIDES WHEN BURNED.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. KEEP OUT OF PUBLIC WATER SUPPLIES.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF VAPOR, MIST OR DUST IS GENERATED, USE
RESPIRATOR APPROVED BY NIOSH OR MSHA AS APPROPIATE. SUPPLIED AIR
RESPIRATOR SHOULD BE USED FOR CLEANING LARGE SPILLS OR UPON ENTRY
INTO TANKS, VESSELS OR OTHER CONFINED SPACES.
Ventilation:ADEQUATE TO MEET COMPONENT EXPOSURE LIMITS.
Other Protective Equipment:EYE BATH AND SAFETY SHOWER.
Work Hygienic Practices:SOILED WORK CLOTHING SHOULD BE LAUNDERED OR
DRY-CLEANED AT LEAST ONCE A WEEK.
Supplemental Safety and Health
USED GASOLINE MOTOR OILS HAVE BEEN SHOWN TO CAUSE SKIN CANCER WHEN
REPEATEDLY APPLIED TO MOUSE SKIN WITHOUT ANY EFFORT TO REMOVE THE
MATERIAL BETWEEN APPLICATIONS. THERE IS NO EVIDENCE OF A CAUSAL REL
ATIONSHIP BETWEEN SKIN CANCER IN HUMANSAND EXPOSURE TO USED MOTOR
OIL.
* Product Identification *
CAGE:OTTJ3
CAGE:OTTJ3
* Composition/Information on Ingredients *
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, SOLVENT-DEWAXED HEAVY
PARAFFINIC
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:ALKENYLSUCCINIMIDE DISPERSANT
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES-MAY CAUSE MINIMAL
IRRITATION. SKIN-BRIEF CONTACT IS NOT IRRITATING. PROLONGED CONTACT
MAY CAUSE DEFATTING OF SKIN OR IRRITATION. INHALATION-VAPORS OR
MIST MAY CAUSE IRRITATION OF THE NOSE & THROAT. INGESTION0NO
ADVERSE EFFECTS EFFECTED. CHRONIC: NO ADVERSE EFFECTS EXPECTED.
Explanation of Carcinogenicity:NONE OF THE INGREDIENTS IN THIS PRODUCT
IS LISTED BY NTP, IARC OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYES:TEMPORARY DISCOMFORT. SKIN: LOCAL REDNES
WITH POSSIBLE MILD DISCOMFORT. INHALATION: HEADACHE, NAUSEA,
DROWSINESS. INGESTION: DISCOMFORT, NAUSEA, DIARRHEA MAY OCCUR.
Medical Cond Aggravated by Exposure:BECAUSE OF ITS DEFATTING
PROPERTIES, PROLONGED AND REPEATED SKIN CONTACT MAY AGGRAVATE AN
EXISTING DERMATITIS.
* First Aid Measures *
IRRITATION PERSISTS, SEE DOCTOR. SKIN: WASH WITH SOAP & WATER FOR
SEVERAL MIN. IF IRRITATION PERSISTS, SEE DOCTOR. INGESTION: IF MORE
THAN SEVERAL MOUTHFULS HAVE BEEN SWALLOWED, GIVE 2 GLASSES OF
WATER. GET MEDICALA TTENTION. INHALATION: REMOVE VICTIM TO FRESH
AIR. GET MEDICAL ATTENTION IF BREATHING BECOMES DIFFICULT.
* Fire Fighting Measures *
Flash Point Method:COC
Lower Limits:N.D.
Upper Limits:N.D.
Extinguishing Media:ACCORDING TO NFPA GUIDE, USE WATER SPRAY, DRY
CHEMICAL, FOAM OR CARBON DIOXIDE. WATER OR FOAM MAY CAUSE FROTHING.
Fire Fighting Procedures:USE WATER TO COOL FIRE-EXPOSED CONTAINERS. IF
A LEAK OR SPILL HAS NOT IGNITED, USE WATER SPRAY TO DISPERSE THE
VAPORS & TO RPOVIDE PROTECTION FOR FIRE PERSONS.
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA. AVOID BREATHING VAPOR. USE
SELF-CONTAINED BREATHING APPARATUS. CONTAIN SPILL IF POSSIBLE. WIPE
UP OR ABSORB ON SUITABLE MATERIAL & SHOVEL UP. PREVENT ENTRY INTO
SEWERS & WATERWAYS. AVO ID CONTACT WITH SKIN, EYES OR CLOTHING.
*Handling and Storage *
Handling and Storage Precautions:MINIMUM FEASIBLE HANDLING TEMPERATURES
SHOULD BE MAINTAINED. PERIODS OF EXPOSURE TO HIGH TEMPERATURES
SHOULD BE MINIMIZED. AVOID WATER CONTAMINATION.
Other Precautions:AVOID EYE AND SKIN CONTACT. DO NOT BREATHE VAPORS.
* Physical/Chemical Properties *
HCC:V6
Boiling Pt:B.P. Text:N.D.
Melt/Freeze Pt:M.P/F.P Text:N.D.
Decomp Temp:Decomp Text:N.D.
Vapor Pres:N.D.
Vapor Density:N.D.
pH:N.A.
Evaporation Rate & Reference:N.D.
Solubility in Water:NEGLIGIBLE
Appearance and Odor:PALE LIQUID.
Corrosion Rate:N.D.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
THIS MATERIAL REACTS VIOLENTY WITH: STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
ALDEHYDES, KETONES, OXIDES OF NITROGEN, SULFUR, CALCIUM, ZINC,
PHOSPHORUS.
* Disposal Considerations *
Waste Disposal Methods:THIS PRODUCT HAS BEEN EVALUATED FOR RCRA
CHARACTERISTICS & DOES NOT MEET THE CRITERIA OF A HAZARDOUS WASTE
IF DISCARDED IN ITS PURCHASED FORM. DISPOSE OF WASTE IN ACCORDANCE
WITH ALL FEDERAL, STATE AN D LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:AVOID INHALATION.
Ventilation:ADEQUATE. IF USING INDOORS, OPEN ALL WINDOWS & DOORS.
Supplemental Safety and Health
* Product Identification *
CAGE:0K1A4
* Composition/Information on Ingredients *
Ingred Name:THIXOTROPIC MEDIUM OIL ALKYD RESIN
Ingred Name:MEDIUM OIL ALKYD RESIN
Ingred Name:SOYA BASED ALKYD RESIN
Ingred Name:STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITANT. INGESTION:
HARMFUL/FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
Medical Cond Aggravated by Exposure:PRE-EXISTING LUNG DISORDERS.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. SKIN: WASH THOROUGHLY W/SOAP
& WATER. EYES: FLUSH W/PLENTY OF WATER. INGESTION: DON'T INDUCE
VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:SCC
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEMICAL/CO2.
Fire Fighting Procedures:WEAR SCBA & PROTECTIVE CLOTHING. USE WATER
SPRAY TO COOL CONTAINERS. DON'T USE A DIRECT STREAM OF WATER.
Unusual Fire/Explosion Hazard:COMBUSTIBLE. PRODUCT MAY FLOAT & CAN BE
REIGNITED ON SURFACE OF WATER. CONTAINERS EXPOSED TO INTENSE HEAT
CAN BUILD UP & RESULT IN CONTAINER RUPTURE.
* Accidental Release Measures *
Spill Release Procedures:SMALL: ABSORB W/SAND/OTHER SUITABLE MATERIAL,
THEN PLACE IN A CONTAINER FOR DISPOSAL. LARGE: EVACUATE AREA, MAY
BE SLIPPERY. DIKE AROUND W/ABSORBENT MATERIAL & TRANSFER LIQUIDS &
CONTAMINATED MATERIAL TO SEPARATE, SUITABLE CONTAINERS FOR
RECOVERY.
*Handling and Storage *
Handling and Storage Precautions:DON'T USE/STORE NEAR
HEAT/SPARKS/FLAMES/OTHER SOURCES OF IGNITION. CLOSE CONTAINER AFTER
EACH USE. IF USING INDOORS, OPEN ALL WINDOWS & DOORS.
Other Precautions:CONTAINS MINERAL SPIRITS. AVOID CONTACT W/SKIN &
EYES. DON'T TAKE INTERNALLY. AVOID INHALATION & USE ONLY W/ADEQUATE
VENTILATION. KEEP OUT OF REACH OF CHILDREN.
* Physical/Chemical Properties *
Vapor Density:4-8
Evaporation Rate & Reference:(BU AC = 1): <1
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORED VISCOUS LIQUID W/PETROLEUM SOLVENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME/OTHER SOURCES OF
IGNITION.
Hazardous Decomposition Products:THERMAL INCOMPLETE COMBUSTION:
HYDROCARBON FUMES, SMOKE, CO.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NOT NECESSARY. MINIMIZE INHALATION OF
DUST.
Ventilation:NO SPECIAL REQUIREMENTS.
Other Protective Equipment:NOT NECESSARY.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING IF ANY MATERIAL
GETS ON SKIN.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:MAGNETITE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:STYRENE ACRYLATE COPOLYMER
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLYPROPYLENE
Fraction by Wt: 3.5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:METAL COMPLEX OF AZO-COMPOUNDS
Fraction by Wt: 1%
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY TRACT
IRRITATION MAY OCCUR. SKIN: ABSORPTION THROUGH INTACT SKIN IS NOT
EXPECTED. NOT EXPECTED TO BE IRRITATING TO SKIN. EYES: IF PRODUCT
COMES IN CONTACT WITH EYES IT MAY CAUS E IRRITATION. INGESTION: IN
NORMAL USE,INGESTION UNLIKELY, BUT IF INGESTED MAY IRRITATE THE GI
TRACT.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
* First Aid Measures *
MIN WHILE FORCIBLY HOLDING EYELIDS APART TO ENSURE COMPLETE
IRRIGATION OF ALL EYE & LID TISS. GET MED ATTN IF NEEDED. SKIN:
WASH THORO W/SOA P & WATER. INHAL: REMOVE FROM EXPOS. IFBRTHG
DFCLT/OTHER SYMP PRESENT GET MED ATTN. INGEST: DILUTE BY DRINKING
LG QTYS WATER; IF VOMIT OCCURS, ADMIN MORE WATER. GET MED ATTN IF
NEEDED.
* Fire Fighting Measures *
Extinguishing Media:WATER, FOAM, DRY CHEMICAL OR CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
* Accidental Release Measures *
Spill Release Procedures:PICK UP OR SWEEP UP AND STORE PROPERLY OR
DISPOSE OF IN ACCORDANCE WITH ALL LEGAL REQUIREMENTS.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:STORE IN ORIGINAL CONTAINER. STORE IN
COOL, DRY PLACE.
Other Precautions:
* Physical/Chemical Properties *
Solubility in Water:INSOLUBLE; < 0.1%
Appearance and Odor:FINE BLACK POWDER; NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:MAY INCLUDE CARBON MONOXIDE, CARBON
DIOXIDE AND OXIDES OF NITROGEN.
* Disposal Considerations *
Waste Disposal Methods:NO SPECIAL TECHNIQUES BEYOND NORMAL PRACTICE.
INSURE CONFORMITY WITH FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NORMALLY NOT NECESSARY, A NIOSH APPROVED ORGANIC
VAPOR CANISTER MAY BE USED.
Ventilation:MECHANICAL/LOCAL EXHAUST: LARGE QUANTITIES USED TO 2 PPM.
Other Protective Equipment:APRON PROTECTS CLOTHING FROM HARDENED GLUE,
SOAP & WATER HELPS REMOVE ADHESIVE FROM SKIN.
Supplemental Safety and Health
POLYMETHYLMETHACRYLATE IMPLANTED UNDER THE SKIN OF EXPERIMENTAL ANIMALS
CAUSED TUMORS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ETHYL-2-CYANOACRYLATE
Other REC Limits:2-5 PPM
Ingred Name:POLYMETHYLMETHACRYLATE, METHYL METHACRYLATE POLYMER
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MUCOUS MEMBRANES W/SOME
COUGHING. EYES: IRRITATION, TEARING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: MUCOUS MEMBRANES W/SOME COUGHING.
EYES: IRRITATION, TEARING.
Medical Cond Aggravated by Exposure:SKIN, EYE & RESPIRATORY DISORDERS
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. SKIN: FLUSH AREAS OF CONTACT
W/WATER. WIPE AWAY LIQUID ADHESIVE WHERE POSSIBLE W/RESIDUALS BEING
REJECTED BY SOAKING IN WATER. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:FLUSH W/LARGE AMOUNTS OF WATER OR DRY CHEMICAL
EXTINGUISHER.
Fire Fighting Procedures:FUMES MAY BE IRRITATING IF NOT BURNING &
WATER OR DRY CHEMICAL.
Unusual Fire/Explosion Hazard:NONE, COMBUSTIBLE REQUIRING THE ABOVE
PROCEDURES.
* Accidental Release Measures *
Spill Release Procedures:ABSORB W/PAPER TOWELS OR CLOTH; SWEEP INTO
TRAY FOR LIQUID TO BE REACTED W/WATER FOR SOLID WASTE TREATMENT.
AVOID OVER EXPOSURE TO FUMES W/LARGE SPILLS & POOR VENTILATION.
*Handling and Storage *
Handling and Storage Precautions:AVOID MOISTURE, DIRECT UV-SUNLIGHT &
Other Precautions:AVOID BREATHING VAPOR, CONTACT W/EYES & SKIN. DON'T
STORE AT -5C WHICH FREEZES PRODUCT TO USELESS STATE. PRODUCT NOT
DAMAGED BY FREEZING.
* Physical/Chemical Properties *
Vapor Pres:1
Solubility in Water:INSOLUBLE
Appearance and Odor:TRANSPARENT WATER-WHITE TO STRAW COLORED LIQUID
W/STIMULATIVE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
WATER, ALCOHOL, AMINES, ALKALINE MATERIALS & DIOXIDE.
UV-SUNLIGHT.
Hazardous Decomposition Products:CO, CO2
* Disposal Considerations *
Waste Disposal Methods:INCINERATE SOLID COMBUSTIBLE WASTE OR DUMP AS
CHEMICAL WASTE ACCORDING TO LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:DUST MASK.
Ventilation:MECHANICAL (GENERAL) ROOM VENTILATION IS NORMALLY ADEQUATE.
LOCAL EXHAUST MAY BE REQUIRED IF WORK AREA NOT VENTED.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS.
* Product Identification *
Product ID:BOROCIL IV
* Composition/Information on Ingredients *
Ingred Name:SODIUM METABORATE TETRAHYDRATE
Other REC Limits:NONE SPECIFIED
Ingred Name:BROMACIL
Fraction by Wt: 4%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 PPM
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:WHEN INGESTED, WILL IRRITATE THE
GASTROINTESTINAL TRACT AND AFFECT THE CENTRAL NERVOUS SYSTEM.
ITTITATING TO THE MUCOUS MEMBRANES WHEN INHALED. WHEN CONTACTED IN
THE EYES OR ON THE SKIN, MAY BE AN IRR ITANT.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:NAUSEA, DIARRHEA, RASHES, DEPRESSION AND COMA.
MAY CAUSE IRRITATION OF NOSE, EYES, THROAT AND SKIN.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
* First Aid Measures *
First Aid:INGESTION: EMETIC, COPIOUS FLUSHING WITH WATER. OBTAIN
MEDICAL ATTENTION. INHALATION: OBTAIN MEDICAL ATTENTION. REMOVE TO
AND CALL APHYSICIAN. SKIN: WASH WITH SOAP AND WATER.
* Fire Fighting Measures *
Flash Point:NON-FLAMMABLE
Extinguishing Media:USE PROPER MEDIA TO EXTINGUISH THE SOURCE OF FIRE.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP AND SHOVEL INTO CONTAINERS.
Neutralizing Agent:NOT APPLICABLE.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT
CONTAINERS FROM PHYSICAL DAMAGE.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE MIST. AVOID
CONTACT WITH EYES. USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY
AFTER HANDLING. DO NOT STORE IN DIRECT CONTACT WITH GROUND OR
CONCRETE FLOOR.
* Physical/Chemical Properties *
HCC:T5
Solubility in Water:SOLUBLE GRANULES
Appearance and Odor:WHITE CRYSTALLINE SOLID, ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS.
| 1 | gloves_mandatory |
Control Measures
*
Proprietary Ind: Y
*
Contractor Summary
*
*
Item Description Information
*
Item Manager: S9M
Item Name: HOMATROPINE HYDROBROMIDE OPTHALMIC SOLUTION, USP
Type/Grade/Class: MEDICAL STRENGTH=5%
Unit of Issue: BT
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Effects of Exposure: ACUTE: INHALATION: MAY BE IRRITATING TO MUCOUS MEMBRANES
AND RESPIRATORY TRACT. SKIN CONTACT:PRODUCT CONFORMS TO FDA REGULATIONS AND
GUIDELINES FOR AN OPHTHALMIC FORMULATION AND THUS IS NOT EXPECTED TO PRODUCE
DERMAL IRRITATION. EYE CONTACT: PRODUCT CONFORMS TO FDA REGULATIONS AND
GUIDELINES FOR AN OPHTHALMIC FORMULATION THAT HAS BEEN DEMONSTRATED TO BE
SAFE FOR USE IN THE EYE. MINIMAL OCULAR IR RITATION MAY OCCUR FOLLOWING AN
EXCESSIVE EXPOSURE BEYOND THERAPEUTIC LEVELS SUCH AS IN PRODUCT ABUSE OR
INDUSTRIAL ACCIDENT. SYSTEMIC EFFECTS IS POSSIBLE WITH EXCESSIVE TOPICAL
OCULAR EXPOSURE. (CONT D. SEE "ECOLOGIAL")
Explanation Of Carcinogenicity: NOT DETERMINED
Signs And Symptions Of Overexposure: EYE, SKIN, INHALATION: RESPIRATORY TRACT
IRRITATION, BLURRED VISION, DRY MOUTH, NOSE AND THROAT, INCREASED INTRAOCULAR
PRESSURE, TRANSIENT BRADYCARDIA FOLLOWED BY TACHYCARDIA WITH PALPITATIONS AND
ARR YTHMIAS. POSSIBLE ALLERGIC REACTION TO DUST IF INHALED.
Medical Cond Aggravated By Exposure: NOT PROVIDED BY MFR
First Aid: INHALATION:MOVE TO FRESH AIR. IF NOT BREATHING, PERFORM ARTIFICIAL
RESUSCITATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN. OBTAIN MEDICAL
ATTENTION. SKIN: IN EVENT OF ADVERSE EFFECTS, OBTAINMEDICAL A TTENTION.
ADVERSE EFFECTS, OBTAIN MEDICAL ATTENTION. INGESTION: FLUSH MOUTH WITH WATER.
IN TREATMENT OF AN OVERDOSE, EMESIS OR LAVAGE OF STOMACH WITH 4% TANNIC
ACID SOLUTION AND ADMINISTRATION OF ACTIVATED CHARCOAL RECOMMENDED. OBTAIN
MEDICAL ATTENTION.
*
Handling and Disposal
*
Spill Release Procedures: WEAR APPROVED RESPIRATOR AND CHEMICALLY COMPATIBLE
WASTE DISPOSAL. VENTILATE AREA AND WASH SPILL SITE AFTER MATERIAL PICKU P IS
COMPLETE
Neutralizing Agent: NOT PROVIDED BY MFR
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH ALL APPLICABLE FEDERAL
STATE, AND LOCAL LAWS. THIS PRODUCT DOES NOT MEET THE DEFINITION OF HAZARDOUS
Handling And Storage Precautions: STORE IN TIGHT CONTAINER AS DEFINED IN THE
UNITED STATES PHARMACOPEIA. THIS MATERIAL SHOULD BE HANDLED AND STORED PER
LABEL AND OTHER INSTRUCTIONS TO ENSURE PRODUCT INTEGRITY. DO NOT PERMIT
EATING, DR INKING OR SMOKING NEAR MATERIAL.
Other Precautions: AVOID CONTACT WITH EYES, SKIN OR CLOTHING. AVOID BREATHING
DUST OR MIST. USE WITH ADEQUATE DUST CONTROL. WASH THOROUGHLY AFTER HANDLING.
DO NOT PERMIT EATING, DRINKING, OR SMOKING NEAR MATERIAL.
*
Fire and Explosion Hazard Information
*
Extinguishing Media: USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING FIRE
CONDITIONS.
Fire Fighting Procedures: WEAR SELF CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard: NONE. TOXIC GASES PRODUCED: CARBON OXIDES,
NITROGEN OXIDES.
*
*
Respiratory Protection: NIOSH/OSHA-APPROVED RESPIRATOR.
Ventilation: USE GENERAL OR LOCAL EXHAUST.
Other Protective Equipment: PROTECT EXPOSED SKIN. APPROPRIATE LABORATORY
APPAREL. SELF CONTAINED BREATHING APPARATUS SHOULD BE USED WHEN FIGHTING
FIRES INVOLVING A CHEMICAL.
Work Hygienic Practices: NOT PROVIDED BY MFR
Supplemental Safety and Health: MSDS ALSO COVERS ISOPTO HOMATROPINE, 5% - 5 ML
*
Physical/Chemical Properties
*
HCC: T6
Decomp Text: NOT PROVIDED BY MFR
PH: NOT PROVIDED
Viscosity: NOT PROVIDED BY MFR
Solubility in Water: ALL COMPONENTS SOLUBLE.
Appearance and Odor: AQUEOUS SOLUTION.
Percent Volatiles by Volume: NOT PROVIDED
Corrosion Rate: NOT PROVIDED BY MFR
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: MATERIAL IS STABLE FROM A SAFETY POINT OF VIEW.
Materials To Avoid: ALKALIES, IODINE.
Hazardous Decomposition Products: MATERIAL EMITS TOXIC FUMES WHEN HEATED TO
DECOMPOSITION.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: WILL NOT OCCUR.
*
Toxicological Information
*
Toxicological Information: USED MEDICINALLY ONLY IN THE EYE BT REPORTS OF CNS
INVOLVEMENT HAVE APPEARED FOLLOWING USE OF HOMATROPINE EYE DROPS. HOMATROPINE
TROPINE INCLUDE DRYNESS OF THE MOUTH WITH DIFFICULTY IN SWALLOWING, THIRST,
DILATION OF THE PUPILS WITH LOSS OF ACCOMMODATION AND PHOTOPHOBIA, INCREASED
INTRAOCULAR PRESSURE, FLUSHING AND DRYNESS OF T HE SKIN, TRANSIENT
BRADYCARDIA FOLLOWED BY TACHYCARDIA WITH PALPITATIONS AND ARRYTHMIAS.
POSSIBLE ALLERGIC REACTION TO DUST IF INHALED, INGESTED OR IN CONTACT WITH
SKIN. POISONOUS.
*
Ecological Information
*
Ecological: (CONTD, FROM "HEALTH HAZARDS") INGESTION: THE CONCENTRATION OF
PRODUCT POSSESSES A SIGNIFICANT ORAL HAZARD TO CHILDREN SHOUL D ACCIDENTAL OR
INTENTIONAL INGESTION OCCUR. CHRONIC EXPOSURE: POSSIBLE HYPERSENSITIZATION
AND DEVELOPMENT OF SYSTEMIC EFFECTS NOTED UNDER ACUTE HAZARDS.
*
*
Transport Information: THIS PRODUCT DOES NOT POSE AN UNREASONABLE RISK TO
HEALTH AND SAFETY OR PROPERTY WHEN TRANSPORTED IN COMMERCE. THE HAZARD CLASS
*
Regulatory Information
*
*
Other Information
*
Other Information: HAZARD RATINGS: HEALTH: 1; FLAMMABILITY: 0; REACTIVITY: 0;
PPE: NPU. AS A GENERAL RULE, INDIVIDUALS WORKING WITH CHEMICALS SHOULD
CONSIDER ALL CHEMICALS TO BE POTENTIALLY HAZARDOUS EVEN IF THEIR INDIVIDUAL
HAZARDS ARE UNCHARACTERIZED OR UNKNOWN.
*
Transportation Information
*
Multiple KIT Number: 0
Unit Of Issue: BT
Additional Data: TRANSPORTATION DATA PER MANUFACTURER'S MSDS. THIS PRODUCT DOES
NOT POSE AN UNREASONABLE RISK TO HEAL TH AND SAFETY OR PROPERTY WHEN
ARE NOT APPLICABLE TO THIS PRODUCT.
*
Detail DOT Information
*
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail IMO Information
*
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
*
Detail IATA Information
*
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail AFI Information
*
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
HAZCOM Label
*
Company Name: ALCON LABORATORIES INC
Label Required IND: Y
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: STORE IN TIGHT CONTAINER AS DEFINED IN U.S.
PHARMACOPEIA. HANDLE AND STORE PER LABEL AND OTHER INSTRUCTIONS TO ENSURE
PRODUCT INTEGRITY. DO NOT EAT DRINK OR SMOKE NEAR PRODUCT. AVOID CONTACT WITH
EYES , SKIN, OR CLOTHING. AVOID BREATHING DUST OR MIST. USE WITH ADEQUATE
DUST CONTROL. WASH THOROUGHLY AFTER HANDLING. INHALATION: MAY BE IRRITATING
TO MUCOUS MEMBRANES AND RESPIRATORY TRACT. EYE CONTACT : PRODUCT CONFORMS TO
FDA REGULATIONS AND GUIDELINES FOR AN OPHTHALMIC FORMULATION THAT HAS BEEN
DEMONSTRATED TO BE SAFE FOR USE IN THE EYE.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED ORGANIC VAPOR CANISTER
OR NIOSH/MSHA APPROVED SUPPLIED AIR RESPIRATORY PROTECTION WHEN TLV
IS EXCEEDED.
Ventilation:ALL APPLIC AREAS SHOULD BE PROVIDED W/SUFFICIENT MECHANICAL
VENT W/EXPLOS PROOF EQUIP TO MAINTAIN EXPOS LEV BELOW TLV.
Other Protective Equipment:USE PROTECTIVE CREAM WHERE SKIN CONTACT IS
LIKELY. WEAR IMPERVIOUS CLOTHING AND BOOTS.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING WASHROOM.
SMOKE IN SMOKING AREA ONLY.
Supplemental Safety and Health
FIRE FIGHT PROC:BURNING, GIVING OFF CARBON MONOXIDE AND CARBON DIOXIDE,
ETC.
* Product Identification *
CAGE:0ALO9
CAGE:0ALO9
* Composition/Information on Ingredients *
Fraction by Wt: <5%
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Fraction by Wt: <5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:ADVERSE HEALTH EFFECTS FROM
VAPORS OR SPRAY MISTS IN POORLY VENTILATED AREAS MAY INCLUDE
IRRITATION OF MUCOUS MEMBRANES OF NOSE, THROAT AND RESPIRATORY
TRACT AND SYMPTOMS OF HEADACHE AND NAUSEA.SKIN & EYE
CONTACT:PROLONGED OR REPEATED EXPOSURE TO PRODUCT MAY CAUSE SKIN
IRRITATION. (EFTS OF OVEREPXOS)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:DIRECT CONTACT WITH PRODUCT MAY RESULT
IN EYE IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR. EYE:PROMPTLY & THORO WASH W/WATER
CONTAM CLTHG, WASH THORO W/SOAP & WATER, WASH CLTHG BEFORE REUSE.
INGEST:IF VICTIM IS CONSCIOUS, GIVE 2 GLASSES OFWATER TO DRINK &
CALL A MD. DO NOT GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:PAINT WILL NOT BURN UNTIL WATER HAS EVAP. FOR
RESIDUAL SOLIDS USE:FOAM/ALCOHOL FOAM, CARBON DIOXIDE, DRY
CHEM/WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . MATL CAN SPLATTER IF TEMP EXCEEDS BOILING
PT. RESIDUAL SOLIDS ARE CAPABLE OF (SUPDAT)
Unusual Fire/Explosion Hazard:CLSD CONTRS MAY EXPLODE WHEN EXPOS TO
EXTREME HEAT. WATER MAY BE USED TO COOL UNRUPTURED CONTRS. AVOID
SPREADING BURNING LIQ W/WATER USED FOR COOLING PURPOSES.
* Accidental Release Measures *
Spill Release Procedures:RECOVER FREE LIQUID. PICK UP REMAINING LIQUID
WITH ABSORBENT MATERIAL AND PLACE INTO CONTAINER FOR DISPOSAL. WASH
AREA WITH WATER AND DETERGENT. DO NOT WASH INTO PUBLIC WATER
SOURCES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:PROD SHOULD BE STORED AT ROOM TEMP TO
PRLNG STORAGE LIFE. KEEP FROM FREEZING SO PROD DOES NOT COAGULATE.
Other Precautions:SHAKE/STIR WELL BEFORE USING. DO NOT TAKE INTERNALLY.
AVOID PRLNGD CONT W/SKIN/BRTHG OF SPRAY MIST. CLOSE CONTR AFTER
EACH USE. KEEP AWAY FROM CHILDREN. THESE PRODS CONTAIN NO LEAD
PIGMENTS.
* Physical/Chemical Properties *
HCC:B3
Vapor Pres:SEE INGS
Vapor Density:LTR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:DILUTABLE
Appearance and Odor:THICK LIQUID, WHITE AND VARIOUS COLORS, SLIGHT
AMONIA ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:WHEN PRODUCT IS HEATED TO
DECOMPOSITION IT MAY PRODUCE FUMES WHICH CONTAIN CARBON MONOXIDE
AND CARBON DIOXIDE, ETC.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. BEFORE ATTEMPTING CLEAN UP, REFER TO HAZARD
CAUTION INFORMATION IN OTHER SECTIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF VENTD,MAY NOT REQ RSPRTR.IN RESTRICTD
VENT,NIOSH CHEM CARTRIDGE RSPRTR MAY BE REQ'D.SPRAYNG,MECHAN
PREFILTER MAY ALSO BE REQ'D.CONFIND AREAS,USE AIR SUPPLD RSPRTR.SEE
GUIDELINE"AIHA
Ventilation:LOCAL EXHAUST VENT TO KEEP BELOW TLV. REMOVE DECOMPOSITION
PRODUCT. SEE "INDUST VENT-MANUAL RECOMMENDED PRACTICES" ACGIH
Other Protective Equipment:EYEWASH FACILITY, SAFETY SHOWER.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:W A ELLISON
* Composition/Information on Ingredients *
(LFL 1.7; UFL 7.6)
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
(LFL 1.0; UFL 7.0)
Other REC Limits:NONE RECOMMENDED
Ingred Name:TITANIUM DIOXIDE (PIGMENT)
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICA, CRYSTALLINE (PIGMENT)
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICA, CRYSTALLINE - TRIPOLI
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TALC (PIGMENT)
Other REC Limits:NONE RECOMMENDED
Ingred Name:METHYL ISOAMYL KETONE (SOLVENT)
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
(LFL: 1.0 UFL: 7.0)
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:UNKNOWN IARC:YES
Health Hazards Acute and Chronic:ACUTE; INGEST: GASTROINTESTINAL IRRIT,
NAUSEA, VOMITING. ASPIRATION INTO LUNG MAY CAUSE CHEM PNEUMONITIS
(CAN BE FATAL). INHAL: NOSE OR THROAT IRRIT. ACUTE CENTRAL NERVOUS
SYSTEM DEPRESSION (HEADACHES , DIZZINESS, NAUSEA, CONFUSION). EYE:
SEVERE IRRIT. SKIN: ABSORBED THROUGH SKIN IN HARMFUL AMTS.
DEFATTING & SKIN IRRIT.
Explanation of Carcinogenicity:IARC CONSIDERS CRYSTALLINE SILICA TO
HAVE LIMITED EVIDENCE OF CARCINOGENICITY IN HUMANS & SUFFICIENT IN
ANIMALS.
Effects of Overexposure:CHRONIC; SILICOSIS (DISABLING LUNG DISEASE).
LIVER, KIDNEY AND BLOOD INJURY. ENHANCES NEUROTOXICITY (SYNERGISTIC
EFFECT RESULTED IN PERIPHERAL NEUROPATHY). PROLONGED & REPEATED
OVEREXPOSURE: PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
CONCENTRATING & INHALING PRODUCT MAY BE HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY CONDITIONS
MAY BE AGGRAVATED BY EXPOSURE TO CRYSTALLINE SILICA.
* First Aid Measures *
First Aid:INGEST: DONT INDUCE VOMITING. CALL POISON CTR/EMERG ROOM/DR
IMMED. INHAL:REMOVE TO FRESH AIR IMMED. IF BREATHING STOPPED, GIVE
ARTIF RESPRTN. KEEP WARM & QUIET. GET MED AID IMMED. EYE: FLUSH
W/WATER 1 5 MIN, LIFTING EYELIDS. GET MED AID. SKIN: REMOVE CONTAM
CLOTHES. WASH AFFECTED AREA W/SOAP & WATER. GET MED AID IF IRRIT
PERSISTS. NOTE TO DR:DIRECT TREATMENT AT CLINICAL CONDITION &
SYMPTOM CONTROL.
* Fire Fighting Measures *
Lower Limits:1.0
Extinguishing Media:NFPA CLASS B EXTINGUISHERS (CO2, DRY CHEMICAL,
ALCOHOL FOAM) FOR FLAMMABLE LIQ. POLYMER FOAM PREFERRED FOR LARGE
FIRES.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE, USE TO COOL EXPOSED
CONTAINERS (FOG NOZZLES PREFERRED) TO PREVENT PRESSURE BUILDUP,
AUTOIGNITION OR EXPLOSION WHEN EXPOSED TO HEAT.
Unusual Fire/Explosion Hazard:DURING EMERGENCY CONDITIONS, OVEREXPOSURE
TO DECOMPOSITION PRODUCTS MAY BE HEALTH HAZARD. SYMPTOMS MAY NOT BE
IMMEDIATELY APPARENT. GET MEDICAL AID. FLAMMABLE.
* Accidental Release Measures *
Spill Release Procedures:KEEP SPECTATORS AWAY. ELIMINATE ALL IGNITION
SOURCES. DIKE & CONTAIN WITH INERT MATERIAL (SAND, EARTH, ETC).
TRANSFER LIQUID OR USED ABSORBENT TO COVERED METAL CONTAINER. USE
NON-SPARKING TOOLS. PREVE NT SEWER, STREAM, OR GROUNDWATER
CONTAMINATION.
*Handling and Storage *
INTERNALLY. DO NOT BREATHE SANDING DUST.
Other Precautions:CLOSE CONTAINER AFTER EACH USE. DO NOT WASH & REUSE
EMPTY CONTAINER FOR ANY PURPOSE. GROUND & BOND CONTAINERS TO
RECEIVING CONTAINER. DO NOT WELD, BRAZE, OR CUT ON EMPTY CONTAINER.
NEVER USE PRESSURETO EMPTY. DRUM IS NOT A PRESSURE VESSEL.
* Physical/Chemical Properties *
Vapor Density:> AIR
Spec Gravity:1.3
pH:4-7
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Solubility in Water:SLIGHT IN WATER
Appearance and Odor:LIQUID, SOLVENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS. OXIDIZING MATERIALS.
OF IGNITION.
Hazardous Decomposition Products:BURNING, INCLUDING WHEN HEATED BY
WELDING OR CUTTING, WILL PRODUCE SMOKE, CARBON MONOXIDE & CARBON
DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE, &
LOCAL LAWS OR REGULATIONS. THIS PRODUCT, IF DISCARDED DIRECTLY,
WOULD BE CLASSIFIED A HAZARDOUS WASTE BASED ON ITS IGNITABILITY
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED SUPPLIED-AIR RESPIRATORY
PROTECTION IN CONFINED OR ENCLOSED SPACES, IF NEEDED.
Ventilation:USE ONLY W/VENT SUFFICIENT TO PVNT EXCEEDING RECOMMENDED
Other Protective Equipment:CHEMICAL-RESISTANT APRON/OTHER IMPERVIOUS
CLTHG TO AVOID CONTAM REGULAR CLTHG WHICH COULD RSLT IN PRLNG/RPTD
SKIN CONT.
Work Hygienic Practices:LAUNDER & DRY-CLEAN CONTAMD CLTHG/SHOES BEFORE
REUSE. CLEANSE SKIN THORO AFTER CONT, BEFORE BREAKS/MEALS, AND (ING
Supplemental Safety and Health
FIRE FIGHT PROC: IGNITED, USE WATER SPRAY TO DISPERSE VAPS & TO PROT
MEN ATTEMPTING TO STOP A LEAK. WATER SPRAY MAY BE USED TO FLUSH
SPILLS AWAY FROM EXPOS. EXPLO HAZ: SPARKS OR OTHER SOURCES OF IGNIT
; THEY MAY EXPLODE & CAUSE INJURY/DEATH. DO NOT ATTEMPT TO CLEAN
SINCE RESIDUE IS DFCLT TO REMOVE. (ING 2)
* Product Identification *
Product ID:MD-4L, COPYMIX FOR MINOLTA ELECTROGRAPHIC 1
* Composition/Information on Ingredients *
Ingred Name:ING 2: ALL OTHER CONTRS SHLD BE DISPOSED OF IN
ENVIRONMENTALLY SAFE MANNER & IN ACCORDANCE W/GOVERNMENTAL
REGULATIONS.
Ingred Name:EFTS OF OVEREXP: EFTS IN MALE RATS. PROD HAS LOW ORDER OF
ACUTE ORAL/DERMAL TOXICITY, BUT MINUTE AMTS ASPIRATED (ING 5)
Ingred Name:ING 4: INTO LUNGS DURING INGEST MAY CAUSE MILD TO SEVERE
PULMONARY INJURY & POSSIBLY DEATH.
Ingred Name:SPILL PROC: DIKING/IMPOUNDING. ADVISE AUTH IF PROD HAS
ENTERED OR MAY ENTER SEWERS/WATERCOURSES/ EXTENSIVE LAND (ING 7)
Ingred Name:ING 6: AREAS. ASSURE CONFORMITY W/APPLIC GOVERN REGS.
CONTINUE TO OBSERVE PREC FOR VOLATILE, COMBUST VAPS FROM (ING 8)
Ingred Name:ING 7: ABSORBED MATL. FOR FURTHER INFO RELATIVE TO SPILLS
RSLTG FROM TRANSPORTATION INCIDENTS, REFER TO LATEST (ING 9)
Ingred Name:ING 8: DOT EMERGENCY RESPONSE GUIDEBOOK FOR HAZ MATLS
Ingred Name:VENT: USE EXPLOSION-PROOF EQUIPMENT.
Ingred Name:HYGIENE PRACT: AT END OF WORK PERIOD. PROD IS READILY
Ingred Name:HYDROTREATED HEAVY NAPHTHA (PETROLEUM); (ISOPAR, CONSISTS
Ingred Name:SUPP DATA: EMPTY DRUMS SHLD BE COMPLETELY DRAINED/PROPERLY
BUNGED/PROMPLY RETURNED TO A DRUM RECONDITIONER. (ING 3)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HLTH STUDIES HAVE SHOWN THAT MANY
PETROLEUM HYDROCARBONS & SYNTH LUBRICANTS POSE POTNTL HUMAN HLTH
RISKS WHICH MAY VARY FROM PERSON TO PERSON. AS A PREC, EXPOS TO
LIQ/VAPS/MISTS/FUMES SHLD BE MINIMIZE D. HIGH VAP CONC (>APPROX
ANESTHETIC, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: AND MAY HAVE OTHER CNS EFTS.
PRLNG/RPTD SKIN CONT W/PROD TENDS TO REMOVE SKIN OILS POSSIBLY
LEADING TO IRRIT/DERMAT. MAY CAUSE EYE IRRITATION. LAB ANIMAL
STUDIES HAVE SHOWN THAT PRLNG/RPTD I NHAL EXPOS TO LIGHT HYDROCARB
VAPS IN THE SAME NAPHTHA BOILING RANGE AS THIS PROD CAN PRDCE
ADVERSE KIDNEY (ING 4)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
IRRIT SUBSIDES. IF IRRIT PERSISTS, CALL MD. SKIN: REMOVE ANY
CONTAMD CLTHG & WASH SKIN THOROUGHLY W/SOAP & WATER. INHAL: REMOVE
FROM EXPOS & CALL MD IMMED. IF BRTHG IS IRREGULAR ORHAS STOPPED,
START RESUSCITATION, ADMINISTER OXYGEN, IF AVAIL. INGEST: DO NOT
INDUCE VOMITING; CALL MD IMMED.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:0.8%
Upper Limits:7%
Extinguishing Media:FOAM, WATER SPRAY (FOG), DRY CHEMICAL, C*O2 &
VAPORIZING LIQUID TYPE EXTINGUISHING AGENTS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER MAY BE INEFTIVE, BUT SHLD BE USED TO KEEP FIRE-EXPOSED
CONTRS COOL. IF LEAK/SPILL HAS (SUPP DATA)
Unusual Fire/Explosion Hazard:EMPTY CONTRS RETAIN RESIDUE (LIQ/VAP) &
CAN BE DANGEROUS. DO NOT PRESSURIZE/CUT/WELD/
BRAZE/SOLDER/DRILL/GRIND OR EXPOSE SUCH CONTRS TO HEAT/FLAME (SUPP
DATA)
* Accidental Release Measures *
Spill Release Procedures:SHUT OFF & ELIM ALL IGNIT SOURCES. KEEP PEOPLE
AWAY. RECOVER FREE PROD. ADD SAND/EARTH/OTHER SUITABLE ABSORB TO
SPILL AREA. MINIMIZE BRTHG VAPS/SKIN CONT. VENT CONFINED SPACES.
OPEN ALL WINDOWS/DOORS. KEEP PROD OUT OF SEWERS/ WATERCOURSES BY
(ING 6)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP PROD AWAY FROM HEAT/SPARKS/PILOT
LIGHTS/ STATIC ELECTRICITY/OPEN FLAME. KEEP CONTRS/STORAGE CONTRS
CLOSED WHEN NOT IN USE.
Other Precautions:DO NOT STORE NEAR HEAT/SPARKS/FLAME OR STRONG
OXIDANTS. TO PVNT FIRE/EXPLOS RISK FROM STATIC ACCUM/DISCHARGE,
EFTIVELY GROUND PROD TRANSFER SYS I/A/W NFPA STD FOR PETROLEUM
PRODS. MINIMIZE BRTHG OF VA PS. AVOID PRLNG/RPTD CONT W/SKIN.
* Physical/Chemical Properties *
HCC:F4
Vapor Density:5
pH:NEUT
Solubility in Water:NEGLIGIBLE; <0.1%
Appearance and Odor:BLACK LIQUID, FAINT PETROLEUM HYDROCARBON ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONT W/STRONG OXIDANTS SUCH AS LIQUID CHLORINE, CONCENTRATED
OXYGEN, SODIUM HYPOCHLORITE OR CALCIUM HYPOCHLORITE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:UNDER FIRE CNDTNS: FUMES, SMOKE,
CARBON MONOXIDE, ALDEHYDES & OTHER DECOMP PRODS, IN THE CASE OF
INCOMPLETE COMBUSTION.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE, AND LOCAL
REGULATIONS .
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:ATMOSPHERIC LEVELS SHOULD BE MAINTAINED BELOW
EXPOSURE GUIDELINE. WHEN RESPIRATORY PROTECTION IS REQUIRED FOR
CERTAIN OPERATIONS, USE NIOSH/MSHA APPROVED AIR-PURIFYING
RESPIRATOR.
Ventilation:GOOD GENERAL VENT SHOULD BE SUFFICIENT OF MOST CONDITIONS.
LOCAL EXHAUST VENT MAY BE NECESSARY FOR SOME OPERATIONS.
Other Protective Equipment:AN EYEWASH & SAFETY SHOWER SHOULD BE NEARBY
& READY FOR USE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
EFTS OF OVEREXP:UPPER RESP IRRIT. ETHYLENE GLYCOL HAS BEEN REPORTED TO
CAUSE BIRTH DEFECTS IN RATS & MICE GIVEN IN HIGH ORAL DOSES WHICH
WERE TOX TO MOTHERS. BIRTH DEFECTS WERE ALSO REPORTED IN MICE A T
HIGH ORAL DOSE WHICH WAS APPARENTLY NONTOX TO MOTHER. FIRST AID
PROC:TO UNCON/CONVULSING PERS. NOTES TO MD: (ING 5)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:WASTE DISP METH:PROPER WASTE DISPOSAL, AS DESCRIBED.
Ingred Name:OTHER PREC:HANDLE EMPTY CONTAINERS AS IF THEY WERE FULL.
Ingred Name:ETHYLENE GLYCOL (SARA III)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:DIETHYLENE GLYCOL
Fraction by Wt: <5%
Ingred Name:POTASSIUM PHOSPHATE, DIBASIC; (DIPOTASSIUM PHOSPHATE)
Fraction by Wt: <5%
Ingred Name:WATER
Fraction by Wt: <5%
Ingred Name:SUPDAT:IF BURN IS PRESENT, TREAT AS ANY THERMAL BURN, AFTER
DECONTAM. CONSULT STD LITERATURE. SUPPORTIVE CARE. (ING 6)
Ingred Name:ING 5:TREATMENT BASED ON JUDGEMENT OF MD IN RESPONSE TO
RXNS OF PATIENT. IN TREATMENT OF INTOX, USE OF ETHANOL, (ING 7)
Ingred Name:ING 6:HEMODIALYSIS & INTRAVENOUS FLUIDS TO CONTROL ACIDOSIS
CHOULD BE CONSIDERED.
Ingred Name:SPILL PROC:ALWAYS WEAR EYE PROT. EXTING ALL IGNIT SOURCES.
FOR SM SPILLS/DRIPS, MOP/WIPE UP & DISP OF IN DOT- (ING 9)
Ingred Name:ING 8:APPRVD WASTE CNTNRS. FOR LG SPILLS, CONTAIN BY DIKING
Ingred Name:ING 9:INTO DOT-APPRVD WASTE CNTNRS; OR ABSORB W/NON-COMBUST
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:HIGH TEMPS MAY GEN VAP
LEVELS SUFFICIENT TO CAUSE IRRIT. EYE:LIQ & MIST MAY IRRIT.
SKIN:PRLNG/RPTD EXPOS IS NOT LIKELY TO CAUSE SIGNIFICANT IRRIT.
MORE SEV RESPONSE MAY RSLT IF SKIN IS ABR ADED. SINGLE PRLNG EXPOS
IS NOT LIKELY TO ABSORB HARMFUL AMTS ALTHOUGH RPTD EXPOS TO LG QTYS
MAY ABSORB(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:HARMFUL AMTS. INGEST:EXCESS EXPOS MAY
CAUSE CNS EFTS, CARDIOPULMONARY EFTS (METABOLIC ACIDOSIS) & KIDNEY
FAILURE. AMTS INGESTED INCIDENTAL TO INDUS HNDLG ARE NOT LIKELY TO
CAUSE INJURY, HOWEV ER, INGEST OF LGR AMTS COULD CAUSE SERIOUS
INJURY, EVEN DEATH. CHRONIC:EXCESS EXPOS MAY CAUSE CNS/KIDNEY EFTS,
&(SUPDAT)
Medical Cond Aggravated by Exposure:NONE REPORTED.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR. GIVE ARTF RESP IF NOT BRTHG.
UPPER & LOWER EYELIDS OCCAS. GET IMMED MED ATTN. SKIN:WASH OFF IN
FLOWING WAT ER/SHOWER. WASH CONTAM CLTHG BEFORE REUSE. INGEST:IF
CONSCIOUS, IMMED INDUCE VOMIT BY GIVING 2 GLASSES OF WATER &
STICKING FINGER DOWN THROAT. GET IMMED MED ATTN. DO NOT GIVE
ANYTHING BY MOUTH(SUPDAT)
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:USE WATER SPRAY, DRY CHEMICAL OR CO*2.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . USE WATER SPRAY TO COOL NEARBY CONTAINERS &
STRUCTURES EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
NIOSH/MSHA APPRVD SCBA IN PRESS DEMAND MODE/SUPPLIED-AIR RESP. IF
SPILL/LEAK IS SM, NIOSH/MSHA APPRVD FULL FACEPIECE AIR-PURIFYING
CARTRIDGE RESP EQUIPPE D FOR ORG VAPS MAY BE SATIS. IN ANY EVENT,
(ING 8)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, DRY, WELL-VENTED PLACE
AWAY FROM INCOMPAT MATLS. VENT CNTNR CAREFULLY AS NEEDED, TO
RELIEVE PRESS. DO NOT GET IN EYES, ON SKIN/CLTHG.
Other Precautions:KEEP CNTNR TIGHTLY CLSD WHEN NOT IN USE. DO NOT USE
PRESS TO EMPTY CNTNR. DO NOT CUT, GRIND, WELD/DRILL ON/NEAR THIS
CNTNR. CNTNRS, EVEN THOSE THAT HAVE BEEN EMPTIED, WILL RETAIN PROD
* Physical/Chemical Properties *
Vapor Pres:2
Vapor Density:>1
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Appearance and Odor:PINK LIQUID; PUNGENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS.
Stability Condition to Avoid:EXCESSIVE HEAT & OPEN FLAMES.
Hazardous Decomposition Products:MAY LIBERATE CARBON MONOXIDE OR CARBON
DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISP OF CONTAM PROD & MATLS USED IN CLEANING UP
SPILLS/LEAKS IN MANNER APPRVD FOR THIS MATL. CONSULT APPROP FED,
STATE & LOC REGULATORY AGENCIES TO ASCERTAIN PROPER DISP PROCS.
NOTE:EMPTY CNTNRS CAN H AVE RESIDUES, GASES & MISTS & ARE SUBJ TO
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF >TLV, USE A NIOSH/MSHA APPROVED PROPERLY
FITTED ORGANIC VAPOR/PARTICULATE RESPIRATOR.
Ventilation:LOCAL EXHAUST: PREFERABLE. GENERAL: ACCEPTABLE.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS AFTER USING. DON'T SMOKE.
Supplemental Safety and Health
CONCENTRATING & INHALING THE CONTENTS CAN BE HARMFUL OR FATAL.
* Product Identification *
Product ID:R2 K 4 XYLOL
* Composition/Information on Ingredients *
Ingred Name:ETHYL BENZENE
Fraction by Wt: 5%
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY TRACT
IRRITATION, NEVOUS SYSTEM DEPRESSION, UNCONSCIOUSNESS, HEADACHE,
DIZZINESS, NAUSEA, LOSS OF COORDINATION, POSSIBLY DEATH. SKIN/EYES:
IRRITATION, REDNESS, ITCHING OR BURNI NG SENSATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: ADVERSE EFFECTS TO LIVER, URINARY &
REPRODUCTIVE SYSTEMS, PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
SKIN/EYES: IRRITATION, REDNESS, ITCHING OR BURNING SENSATION.
* First Aid Measures *
First Aid:INHALATION: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE
BREATHING. KEEP WARM & QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY
INGESTION: NEVER GIV E ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
DON'T INDUCE VOMITING. GIVE SEVERAL GLASSES OF WATER. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1%
Upper Limits:6.7%
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIP & SCBA. WATER SPRAY:
INEFFECTIVE. FOG NOZZLES: PREFERABLE. USE WATER TO COOL FIRE
EXPOSED CONTAINERS TO PREVENT PRESSURE BUILD-UP.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY AUTOIGNITE OR
EXPLODE WHEN EXPOSED TO EXTREME HEAT. APPLICAION TO HOT SURFACES
REQUIRE SPECIAL PRECAUTION.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT/SPARKS/OPEN FLAME.
KEEP AREA VENTILATED. CONSULT NFPA CODE. KEEP CONTAINER CLOSED WHEN
NOT IN USE. AVOID BREATHING VAPOR/MIST.
Other Precautions:EXTINGUISH ALL FLAMES/PILOT LIGHTS/HEATERS. TURN OFF
STOVES/ELEC TOOLS/APPLIANCES. USE APPROVED BONDING/GROUNDING
PROCEDURES. TRANSFER ONLY TO APPROVED CONTAINERS. DON'T TAKE
INTERNALLY. KEEP OUT OF R EACH OF CHILDREN. AVOID SKIN/EYE CONTACT
* Physical/Chemical Properties *
Boiling Pt:B.P. Text:SEE SUPP
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, HOT SURFACES OR
OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:CO2, CO
* Disposal Considerations *
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DON'T
INCINERATE CLOSED CONTAINER. DISPOSE OF IN ACCORDANCE
W/FEDERAL/STATE/LOCAL REGS REGARDING POLLUTION. WASTE MAY BE
HAZARDOUS UNDER RCRA & MUST BE TESTED FOR IGNI TABILITY TO
DETERMINE THE EPA HAZARDOUSNUMBERS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPRVD AIR MASKS IN HIGH CONC
Ventilation:SUFFICIENT WHEN LG AMTS ARE RELEASED, ESP IN LOW AREA
Other Protective Equipment:PROVIDE EYEWASH STATIONS WHERE SPLASHING IS
POSSIBLE
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
III)
Ozone Depleting Chemical:1
* Hazards Identification *
Effects of Overexposure:LIGHT-HEADEDNESS, GIDDINESS, SHORTNESS OF BRTH,
POSS NARCOSIS & CARDIAC ARRHYTHMIAS AT HIGH CONC
* First Aid Measures *
First Aid:INH: REMOVE TO FRESH AIR, CALL MD. DO NOT GIVE EPINEPHRINE OR
SIMILAR DRUGS. SKIN/EYE: FLUSH W/WATER.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:NONFLAMMABLE
Fire Fighting Procedures:SELF-CONTAINED BRTHNG APPAAR FOR VAPORS &
FUMES
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA - ESPECIALLY LOW PLACES WHERE
HEAVY VAPORS MIGHT COLLECT. REMOVE OPEN FLAMES & OTHER IGNIT
SOURCES. FOR LG SPILLS THOSE CLEANING UP MAY REQUIRE APPRVD
SELF-CONTAINED BRTHNG APPAR.
*Handling and Storage *
Handling and Storage Precautions:STORE CONTAINERS IN A CLEAN, DRY AREA.
IN AREAS OF USE.
Other Precautions:VAPORIZATION OF EXCESS AMTS OF PROD CAN
DEPLETE/REPLACE O*2 NEC FOR BREATH. IN CONFINED/ENCLOSED SPACES OR
W/LITTLE VENT THIS MAY BE HEALTH HAZ. HIGH CONC MAY INDUCE CARDIAC
ARRHYTHMIAS.
* Physical/Chemical Properties *
HCC:N1
NRC/State Lic Num:NA
Vapor Density:2.9N
Evaporation Rate & Reference:0.3 (CCL*4)
Solubility in Water:EGLIGIBLE
Appearance and Odor:COLORLESS LIQUID, SLIGHT ETHER ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ALKALI OR ALKALINE EARTH METALS - POWDERED AL, ZN, BE, ETC.
Stability Condition to Avoid:OPEN FLAMES OR HIGH TEMPERATURES
Hazardous Decomposition Products:HYDROCHLORIC & HYDROFLUORIC ACIDS -
POSS PHOSGENE
* Disposal Considerations *
Waste Disposal Methods:MFR RECM EVAPORATE OUTDOORS. DISPOSE W/ FED,
STATE AND LOCAL CODES.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF FORMALDEHYDE IS EMITTED AT LEVELS REQUIRING
RESPIRATORY PROTECTION, THE FOLLOWING RESPIRATOR TYPE SHOULD BE
WORN: FULL FACEPIECE WITH CARTRIDGE OR CANISTER SPECIFICALLY
APPROVED BY NIOSH FOR PROTEC TION AGAINST FORMALDEHYDE, ETC.
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:EYE BATH, SAFETY SHOWER, WASHING FACILITIES.
WEAR PROTECTIVE CLOTHING APPROPIATE FOR RISK OF EXPOSURE.
Work Hygienic Practices:IT IS GOOD INDUSTRIAL HYGIENE PRACTICE TO
MINIMIZE EYE CONTACT. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
WARNING! CONTAINS FORMALDEHYDE. POSSIBLE CANCER HAZARD - MAY CAUSE
CANCER BASED ON ANIMAL DATA. HARMFUL IF INHALED OR SWALLOWED. KEEP
OUT OF REACH OF CHILDREN.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:WATER
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ANIONIC SURFACTANT
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NONIONIC SURFACTANTS
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INHALATION-IT PRODUCES MILD SENSORY
IRRITATION OF THE EYE, NOSE & THROAT AT 2-5 PPM, BECOMES UNPLESANT
IRRITATION. SKIN-CAUSES IRRITATI ON. MAY CAUSE ALLERGIC SKIN
REACTION. INGESTION-EXPECTED TO BE A LOW INGESTION HAZARD.
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:EYES-VAPOR CAUSES EYE IRRITATION AND TEARING.
Medical Cond Aggravated by Exposure:EXPOSURE TO FORMALDEHYDE MAY CAUSE
RESPIRATORY SENSITIZATION IN SOME INDIVIDUALS OR AGGRAVATE
PRE-EXISTING ASTHMATIC CONDITIONS.
* First Aid Measures *
First Aid:INHALATION-MOVE TO FRESH AIR. TREAT SYMPTOMATICALLY. GET
MEDICAL ATTENTION IF SYMPTOMS OCCUR. EYE-IMMEDIATELY FLUSH WITH
REMOVING CONTAMINATED CLOTHES/SHOES. GET MEDICAL ATTENTION.
INGESTED-DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:USE APPROPIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER.
ELIMINATE ALL IGNITION SOURCES. ABSORB SPILL WITH VERMICULITE OR
OTHER INERT MATERIAL, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE.
CLEAN SURFACE THOROUGHL Y TO REMOVE RESIDUAL CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED.
Other Precautions:AVOID BREATHING VAPOR. AVOID CONTACT WITH EYE, SKIN
OR CLOTHING. USE WITH ADEUATE VENTILATION. WASH THOROUGHLY AFTER
HANDLING.
* Physical/Chemical Properties *
HCC:B3
Vapor Density:0.6 AIR=1
pH:9.0
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID, COLORLESS, SLIGHT FORMALDEHYDE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE WITH COMMON MATERIALS AND CONTAMINANTS WITH WHICH THE MATERIAL MAY
REASONABLY COME INTO CONTACT.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE, OR LOCAL LAWS. FLUSH TO SEWER WITH LARGE
AMOUNTS OF WATER.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SCBA REQUIRED.
Other Protective Equipment:FULL WASH RACK GEAR.
Supplemental Safety and Health
NK
* Product Identification *
Preparer's Name:BOB E. FLYNT
* Composition/Information on Ingredients *
Ingred Name:DICHLOROMETHANE
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: 2.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHYL ALCOHOL (ETHANOL)
Fraction by Wt: 8.0%
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: 0.7%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:0.5 PPM
Ingred Name:AMMONIUM HYDROXIDE (CERCLA)
Fraction by Wt: 5.0%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: ABSORPTION, (NARCOSIS,
DIZZINESS, NAUSEA). SKIN: (CORROSION, SCARRING). EYE: CORROSION
(HAZY VISION).
* First Aid Measures *
& WATER. INHAL: REMOVE TO FRESH AIR. INGEST: CALL DR. IMMEDIATELY.
* Fire Fighting Measures *
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:NA
Fire Fighting Procedures:SCBA REQUIRED.
Unusual Fire/Explosion Hazard:MAY PRODUCE TOXIC CHLORIDE FUMES &/OR
PHOSGENE GAS.
* Accidental Release Measures *
Spill Release Procedures:ALLOW TO EVAPORATE. SWEEP UP RESIDUE W/SAWDUST
OR SWEEPING COMPOUND.
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:NA
Decomp Temp:Decomp Text:NA
Vapor Density:2.0
Spec Gravity:1.2
Evaporation Rate & Reference:AS WATER.
Solubility in Water:INSOLUBLE.
Appearance and Odor:VISCOUS LIQUID, W/PUNGENT ODOR.
Corrosion Rate:NA
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ALKALI, STRONG ACIDS, STRONG OXIDIZERS & REACTIVE METALS.
Hazardous Decomposition Products:NONE
* Disposal Considerations *
REGULATORY AGENCIES FOR PROPER DISPOSAL.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR NIOSH APPROVED MECHANICAL FILTER
RESPIRATOR, IF AIRBORNE DUST CONCENTRATION EXCEEDS OSHA STANDARDS.
Ventilation:USE LOCAL EXHAUST IF NECESSARY TO MAINTAIN AIRPORNE DUST
BELOW PEL/TLV.
Other Protective Equipment:WEAR PROTECTIVE CLOTHING TO PREVENT SKIN
IRRITATION FROM DUST.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING DRINKING,
OR SMOKING. LAUNDER CONTAMINATED CLOTHING SEPARATELY AND BEFORE
REUSE.
Supplemental Safety and Health
NON-ASBESTOS FRICTION LINING IS PART OF A PRODUCT CONSISTING OF TWO
PARTS, NON-ASBESTOS FRICTION LINING AND MALLEABLE IRON CASTING.
THIS MSDS CONTAINS DATA PERTAINING TO NON-ASBESTOS FRICTION
LINING.D ATA FOR THE IRON CASTING IS INCLUDED INSEPARATE MSDS UNDER
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:FIBROUS GLASS
Fraction by Wt: 3-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 RDUST Z-3
Ingred Name:CALCIUM CARBONATE (MARBLE) (LIMESTONE)
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:GRAPHITE, NATURAL (CARBON AND GRAPHITE)
Other REC Limits:NONE RECOMMENDED
Ingred Name:CURED RUBBER AND PHENOLIC RESINS
Other REC Limits:NONE RECOMMENDED
Ingred Name:VERMICULITE
Other REC Limits:TLV=5 MG/M3
Ingred Name:BARIUM SULFATE, BARYTES
Other REC Limits:NONE RECOMMENDED
Ingred Name:ARAMID FIBER
Fraction by Wt: 0.5-5%
Other REC Limits:5 FIBRILS/CC MFG
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:BRAKE DUST MAY CAUSE EYE, SKIN, OR
UPPER RESPIRATORY TRACT IRRITATION. MANY STUDIES TO DETERMINE THE
POTENTIAL LONG TERM EFFECTS OF FIBROUS GLASS INHALATION HAVE NOT
SHOWN ANY CONSISTENT EVIDENCE OF P ULMONARY DISEASE, EITHER
MALIGNANT OR NONMALIGNANT.
Effects of Overexposure:EYES: IRRITATION. SKIN: IRRITATION. INHALATION:
IRRITAION OF UPPER RESPIRATORY TRACT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. IF IRRITATION
PERSISTS, GET MEDICAL ATTENTION. SKIN: WASH AREA WITH SOAP AND
WATER. INHALATION: MOVE TO FRESH AIR.
* Fire Fighting Measures *
Extinguishing Media:CARBON DIOXIDE, WATER, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE KNOWN.
* Accidental Release Measures *
Spill Release Procedures:VACUUM OR WET SWEEP ACCUMULATIONS OF BRAKE
DUST. COLLECT IN PROPER CONTAINERS FOR DISPOSAL.
Neutralizing Agent:NONE
*Handling and Storage *
Handling and Storage Precautions:HANDLE WITH ADEQUATE VENTILATION FOR
NUISANCE DUST. DO NOT USE COMPRESSED AIR FOR CLEANING.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:N1
Spec Gravity:1.9-2.2
Appearance and Odor:SOLID. SLIGHT PNELOCIC ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS DUE TO ORGANIC CONTENT.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION MAY RELEASE
TOXIC MATERIALS.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS. THE PRIMARY METHOD OF DISPOSAL IS IN
MUNICIPAL OR INDUSTRIAL LANDFILL.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE A NIOSH APPROVED RESPIRATOR. USE EITHER AN
ATMOSPHERE-SUPPLYING RESPIRATOR OR AN AIR-PURIFYING RESPIRATOR FOR
PARTICULATES.
Ventilation:EXPLOSION-PROOF AS REQUIRED TO KEEP <TLV
Other Protective Equipment:PROTECTIVE CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING/SHOES
BEFORE REUSE. WASH HANDS THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
CON'T: THEREFORE, IN PRACTICE THE REDUCED CATALYST SHOULD BE REMOVED
UNDER A NITROGEN BLANKET WHERE OXIDATION W/AIR IS CONTROLLED &
EXCESS HEAT IS PROPERLY DISSIPATED.
* Product Identification *
Preparer's Name:W C WILLETT
CAGE:SHELO
CAGE:SHELO
* Composition/Information on Ingredients *
Ingred Name:ALUMINUM OXIDE, BAUXITE, ALUMINA, DIALUMINUM TRIOXIDE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION. INHALATION: NOSE,
THROAT & RESPIRATORY TRACT IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: IRRITATION. INHALATION: NOSE, THROAT &
RESPIRATORY TRACT IRRITATION.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN OR RESPIRATORY
DISORDERS
* First Aid Measures *
W/WATER. FOLLOW BY WASHING W/SOAP & WATER. INHALATION: REMOVE TO
FRESH AIR. PROVIDE OXYGEN IF BREATHING IS DIFFICULT. INGESTION:
DON'T INDUCE VOM ITING. DON'T GIVE LIQUIDS TO A VERY DROWSY,
CONVULSING OR UNCONSCIOUS PERSON. GIVE PLENTY OF WATER. REPEAT
LIQUID ADMINISTRATION. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:WILL NOT BURN.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING & A NIOSH
APPROVED SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:IN USE THE CATALYST IS REDUCED & WILL
REACT W/OXYGEN IN AIR TO CAUSE THE CATALYST TO REACH RED HEAT, DUE
TO THE OXIDATION OF THE IRIDIUM. SEE SUPP
* Accidental Release Measures *
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. DON'T DRY SWEEP OR
USE METHODS WHICH INCREASE DUSTING. USE VACUUMING OR SWEEPING
COMPOUND FOR CLEAN-UP. DON'T WASH SPILLS INTO SEWERS OR OTHER
PUBLIC WATER SYSTEMS.
*Handling and Storage *
Handling and Storage Precautions:DON'T EAT & DRINK OR SMOKE IN AREAS
WHERE CATALYST IS PRESENT. KEEP CONTAINERS CLOSED WHEN NOT IN USE.
Other Precautions:ALL PRECAUTIONS GIVEN FOR FRESH CATALYST SHOULD BE
OBSERVED FOR SPENT CATALYST & WASHINGS. AVOID CONTACT W/SKIN.
* Physical/Chemical Properties *
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK GRANULES
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW LEVEL OF CONCERN .
Other Protective Equipment:WEAR LONG SLEEVES,BARRIER CREAMS MAY ALSO
PROVIDE PROTECTION.
Work Hygienic Practices:N/K
Supplemental Safety and Health
PART NO:BASED,NO FINISH CCA SERIES & CFA SERIES.FIRST AID
PROCEDURES:INHALATION:GIVE ARTIFICIAL RESPIRATION IF BREATHING HAS
STOPPED,OR OXYGEN IF NECESSARY.GET MEDICAL ATTENTION IF
NEEDED.ROUTES OF EN TRY:INGESTION .
* Product Identification *
Product ID:CARBON TEXTILE PRODUCTS RAYON (SUP DATA)
* Composition/Information on Ingredients *
Ingred Name:GRAPHITE, SYNTHETIC
Other REC Limits:N/K
Ingred Name:COMPLEX HYDROCARBON "CHAR"
Fraction by Wt: 0-5%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS AND SYMPTOMS OF
OVEREXPOSURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:CARBON FIBERS MAY CAUSE TEMPORARY
IRRITATION.SKIN:CARBON FIBERS MAY CAUSE ITCHING & IRRITATION CAUSED
BY BROKEN FILAMENTS BECOMING IMBEDDED IN THE SKIN.INGESTION:NO
EFFECTS REPORTED.INHALATION:CA RBON FIBERS MAY CAUSE TEMPORARY
IRRITATION TO THE RESPIRATORY TRACT.
Medical Cond Aggravated by Exposure:N/K
* First Aid Measures *
First Aid:EYES:IMMEDIATELY WASH WITH LARGE AMOUNTS OF WATER FOR AT
MEDICAL ATTENTION.SKIN:REMOVE CONTAMINATED CLOTHING IMMEDIATELY AND
WASH SK IN WITH SOAP OR MILD DETERGENT AND WATER FOR 5 MINUTES.IF
IRRITATION PERSISTS,SEEK MEDICAL ATTENTION.INGESTION:SEEK MEDICAL
ATTENTION IF NECESSARY.INHALATION:REMOVE TO FRESH AIR. (SEE SUPP
DATA)
* Fire Fighting Measures *
Extinguishing Media:WATER,DIFFICULT TO IGNITE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.HAZARDOUS DECOMPOSITION
PRODUCTS:CARBON MONOXIDE,CARBON DIOXIDE.
* Accidental Release Measures *
Spill Release Procedures:PREVENT SPREAD OF PARTICLES AND AVOID
DUST-GENERATING CONDITIONS.COLLECT BY VACUUM OR WET METHODS,TAKING
CARE NOT TO GENERATE AIRBORNE FIBERS WHICH CAN CAUSE ELECTRICAL
MALFUNCTIONS.
Neutralizing Agent:N/K
*Handling and Storage *
Handling and Storage Precautions:CARBON FIBERS ARE ELECTRICALLY
CONDUCTIVE & MAY CAUSE SHORT CIRCUITS RESULTING IN DAMAGE TO
ELECTRICAL EQUIP.PROTECT FROM AIRBORNE CONTAMINATION.
Other Precautions:ATTEMPTS TO INCINERATE MAY CAUSE FIBERS TO BECOME
WIDELY DISPERSED AND RESULT IN FAILURES OF ELECTRICAL EQUIPMENT.
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Spec Gravity:1.4-1.9,WATER=1
Appearance and Odor:BLACK TEXTILES-NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:N/K
Hazardous Decomposition Products:CARBON MONOXIDE,CARBON DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .WASTE MATERIAL SHOULD BE
BAGGED OR CONTAINERIZED AND BURIED IN A SANITARY
LANDFILL.INCINERATION MAY DISPERSE FIBERS & CAU SE ELECTRICAL
EQUIPMENT FAILURES.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IN RESTRICTED VENT AREAS, USE NIOSH/MSHA APPRVD
CHEM VAP RESP. IN APPLICATIONS WHERE MISTS/SPRAY MAY BE GENERATED,
AVOID INHAL OF AIRBORNE PARTICULATES BY USING NIOSH/MSHA APPRVD
RESP W/ORG VAP CARTRI DGE W/PREFILTER FOR MIST OR DUST.
Ventilation:GENERAL (MECHANICAL) ROOM VENTILATION WITH LOCAL EXHAUST.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:THOROUGHLY CLEANSE HANDS AFTER HANDLING.
LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
HAZ DECOMP PRODS: OF PHOSPHORUS OXIDE. SPILL PROC: REMOVE W/PAINT
SCRAPER OR STRONG SOLVENT.
* Product Identification *
Product ID:NUCLEAR GRADE VINYL WEATHER BARRIER, WC-1 NG, WHITE
Preparer's Name:JOHN TIDQUIST
* Composition/Information on Ingredients *
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Fraction by Wt: 1%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PHENOL ISOPROPYLATED PHOSPHATE: CAN BE
IRRITATING TO SKIN, RESPIRATORY SYSTEM, MUCOUS MEMBRANES AND EYES.
BREATHING OR INGESTION OF LARGE QUANTITIES MAY CAUSE NEUROLOGICAL
DISTURBANCES WHICH MAY PROGR ESS TO DELAYED NEUROTOXICITY
CHARACTERIZED BY ATAXIA. VINYLACETATE-DIBUTYLMALEATE: EYES:
TEARING, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: STINGING, REDNESS. COUGHING SORENESS
IN RESPIRATORY TRACT, CHEST TIGHTNESS, DIFFICULT BREATHING.
HEXYLENE GLYCOL: IN HIGH CONCENTRATIONS CAN BE AN IRRITANT TO EYES,
SKIN AND MUCOUS MEMBRANES . LARGE ORAL DOSES PRODUCE NARCOSIS.
Medical Cond Aggravated by Exposure:PERSONS WITH PREEXISTING LUNG
DISORDERS MAY BE MORE SUSCEPTIBLE.
* First Aid Measures *
First Aid:SKIN: WASH WITH SOAP AND WATER. EYES: FLUSH WITH CLEAN WATER
REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT, ADMINISTER OXYGEN.
IF IRRIT ATION PERSISTS, CONSULT MD. INGEST: GIVE TWO GLASSES OF
WATER, INDUCE VOMITING, CONSULT MD OR POISON CONTROL CENTER. NEVER
GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:FOAM, ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL,
WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . PRODUCT WILL NOT BURN UNTIL WATER HAS BOILED
OR EVAPORATED.
Unusual Fire/Explosion Hazard:NONE KNOWN.
* Accidental Release Measures *
Spill Release Procedures:FOLLOW HNDLG PROCS. VENT AREA. CNTN LIQ
W/INERT MATLS SUCH AS SAND. ABSORB LIQS USING INERT MATL & SHOVEL
INTO CNTNRS. PVNT PROD FROM ENTERING STREAMS/DRINKING WATER
SUPPLIES. BEFORE DRYING PROD MAY B E WASHED AWAY W/WATER; AFTER
DRYING, (SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID BREATHING VAPORS & APPLICATION
TO HOT SURFACES AS VAPORS MAY BE IRRITATING. KEEP CNTNR CLSD. USE
Other Precautions:FOR INDUSTRY/PROFESSIONAL USE ONLY. NOT INTENDED FOR
RETAIL SALE OR USE BY INDIVIDUAL CONSUMERS. DO NOT REUSE CONTAINER
FOR POTABLES OR EDIBLES.
* Physical/Chemical Properties *
Vapor Pres:SEE INGS
Vapor Density:LTR/AIR
pH:8-9
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:APPRECIABLE
Appearance and Odor:VISCOUS, WHITE PASTE WITH MILD LATEX ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
MATERIALS INCOMPATIBLE WITH WATER.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:THERMAL DECOMP WILL YIELD CARBON
MONOXIDE, CARBON DIOXIDE, TRACE AMTS OF AMMONIA & FORMALDEHYDE &
ACIDIC VAPOR (SUPDAT)
* Disposal Considerations *
Waste Disposal Methods:IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE
AND LOCAL REGULATIONS. REVIEW HAZARD SECTION OF MSDS BEFORE
ATTEMPTING CLEANUP. EMPTY CONTAINERS ARE NON HAZARDOUS UNDER RCRA
AS INDUSTRIAL WASTE.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SOLUTION CONTAINS INGREDIENT 2-7.
Ingred Name:BORATE(1-),TETRAHYDRO-, SODIUM; (SODIUM BOROHYDRIDE)
Fraction by Wt: <0.1%
Ingred Name:ANTIPYRINE,4-AMINO-; (4-AMINOANTIPYRINE)
Fraction by Wt: 0.2%
Ingred Name:ACETIC ACID, (ETHYLENEDINITRILO)TETRA-,DISODIUM SALT;
(DISODIUM ETHYLENEDIAMINE TETRAACETATE)
Fraction by Wt: 0.2%
Ingred Name:1,3-PROPANEDIOL, 2-AMINO-2-(HYDROXYMETHYL)-; (THAM)
Fraction by Wt: 0.2%
Ingred Name:SODIUM CARBONATE(2:1)
Fraction by Wt: 1%
Ingred Name:(DEIONIZED)WATER
Ingred Name:(TIP OF
AMPULE),FERRATE(3-),HEXACYANO-TRI-POTASSIUM;(POTASSIUM
2.5 PARTS COLD WATER. FL PT: NON COMBUSTIBLE.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:POTASSIUM FERRICYANIDE: SKIN & MUCOUS
MEMBRANE IRRITANT. SKIN: MAY CAUSE DERMATITIS. EYE: MAY CAUSE
CONJUNCTIVITIS. INGEST: MAY CAUSE NAUSEA, VOMITING. SORE THROAT,
ABDOMINAL PAIN & DIARRHEA.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:SKIN: WASH AFFECTED AREAS W/SOAP/MILD DETERGENT & LGE AMTS OF
WATER. EYE: FLUSH CONTINUOUSLY W/COPIOUS AMTS OF WATER FOR AT LEAST
EYE & LID TISS. SEEK PROMPT MED ATTN. INGEST: IF CONSCIOUS & NOT
CONVULSIVE, IMMED GIVE VICTIM LGE QTYS OF WATER. SEEK PROMPT MED
ATTN. INHAL: REMOVE TO FRESH AIR. SUPPORT BRTHG(GIVE O*2/ARTF
RESP).
* Fire Fighting Measures *
Flash Point:ING 8
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, WATER SPRAY OR
ALCOHOL FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:
* Accidental Release Measures *
Spill Release Procedures:
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:ATTENTION USER: IF THIS PRODUCT IS
USED AS DIRECTED, THE USER WILL NOT COME IN CONTACT WITH OR BE
EXPOSED TO ANY OF ITS CHEMICAL COMPONENTS.
Other Precautions:
* Physical/Chemical Properties *
HCC:N1
Spec Gravity:ING 8
Solubility in Water:ING 8
Appearance and Odor:POTASSIUM FERRICYANIDE:GRANULAR SOLID,YELLOW/RED
CRYSTALLINE W/MILD SALINE ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
SLOWLY DECOMPOSES IN AQUEOUS SOLUTIONS. PHOTOSENSITIVE CMPD.
Stability Condition to Avoid:MAY BECOME UNSTABLE AT ELEVATED
TEMPERATURES AND PRESSURES.
Hazardous Decomposition Products:WHEN HEATED TO DECOMP/ON CONT
W/ACIDS/ACID FUMES; EMITS HIGHLY TOXIC FUMES OF CYANIDES.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF BY MEANS AS TO COMPLY WITH ALL LOCAL,
STATE & FEDERAL REGULATIONS OR CONTACT AN APPROVED & LICENSED
DISPOSAL AGENCY.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED ORGANIC VAPOR RESPIRATOR, IF
>TLV.
Other Protective Equipment:AS NECESSARY TO PREVENT SKIN & EYE CONTACT.
Supplemental Safety and Health
* Product Identification *
Product ID:R.P. X-RAY DEV./REPL.-PART B
* Composition/Information on Ingredients *
Ingred Name:ACETIC ACID (SARA III)
Ingred Name:1-PHENYL-3-PYRAZOLIDONE
Ingred Name:5-NITROBENZIMIDAZOLE (0.1-0.5%)
Fraction by Wt: 0.5%
* Hazards Identification *
Effects of Overexposure:RESPIRATORY IRRITATION/EYE & SKIN BURNS,
IRRITATION & AN ALLERGIC SKIN REACTION.
* First Aid Measures *
First Aid:INHALATION: REMOVE FROM EXPOSURE. EYES/SKIN: FLUSH WITH
PLENTY OF WATER; GET MEDICAL ATTENTION. IF ALLERGIC SKIN REACTION
DEVELOPS, GET MEDICAL ATTENTION.
* Fire Fighting Measures *
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CO2, FOAM
Fire Fighting Procedures:WEAR SCBA/PROTECTIVE CLOTHING TO PREV. CONTACT
W/SKIN & EYES
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
* Accidental Release Measures *
Spill Release Procedures:NEUTRALIZE WITH BAKING SODA (SODIUM
BICARBONATE) SMALL AMOUNT: FLUSH TO SEWER WITH LGE AMOUNT OF WATER.
LARGE AMOUNT: ABSORB MATERIAL IN VERMICULITE OR OTHESUITABLE
ABSORBENT & PLACE IN IMPERVIOUS CON TAINER.
*Handling and Storage *
Handling and Storage Precautions:KEEP FROM CONTACT WITH OXIDIZING
MATERIALS AND STRONG ALKALI. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:LOCAL EXHAUST OR AN ENCLOSED HANDLING SYSTEM MAY BE
NEEDED TO CONTROL AIR CONTAMINATION TO ACCEPTABLE LEVELS.
* Physical/Chemical Properties *
Spec Gravity:1.1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, ORANGE-BROWN COLORED SOLUTION; PUNGENT.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS & STRONG ALKALI
Hazardous Decomposition Products:CO, CO2, NOX
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN AN APPROVED INCINERATOR OR CONTRACT
WITH LICENSED CHEMICAL WASTE DISPOSAL AGENCY. DISCHARGE, TREATMENT
OR DISPOSAL MAY BE SUBJECT TO FEDERAL, STATE OR LOCAL LAWS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED UNDER NORMAL USE.
Ventilation:NATURAL VENTILATION IS ADEQUATE.
Other Protective Equipment:WEAR REGULAR WORK CLOTHES, INCLUDING
LONG-SLEEVED SHIRT & TROUSERS.
Work Hygienic Practices:USE NORMAL PERSONAL HYGIENE AND FOLLOW GOOD
HOUSEKEEPING PRACTICES.
Supplemental Safety and Health
THIS MEDICINE IS FOR THERAPEUTIC USE ONLY. OCCUPATIONAL HAZARDS ARE NOT
FULLY UNDERSTOOD.
* Product Identification *
Product ID:NALOXONE HYDROCHLORIDE INJECTION
Preparer's Name:GREGORY KOLAR
* Composition/Information on Ingredients *
Ingred Name:NALOXONE HYDROCHLORIDE
Other REC Limits:NONE RECOMMENDED
Ingred Name:METHYL PARABEN 1.8 MG/ML
Other REC Limits:NONE RECOMMENDED
Ingred Name:PROPYLPARABEN (PROPYL 4-HYDROXYBENZOATE) 0.2 MG/ML
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM CHLORIDE 8.6 MG/ML
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE, SKIN AND RESPIRATORY TRACT
IRRITATION MAY OCCUR.
Effects of Overexposure:IRRITATION.
Medical Cond Aggravated by Exposure:NONE KNOWN
* First Aid Measures *
MINUTES. SKIN-WASH WITH SOAP & WATER; THEN FLUSH WITH WATER UNTIL
CHEMICAL IS REMOVED. INGESTION-RINSE MOUTH WITH WATER, DRINK 2 TO 4
GLASSES OFWATER AND IMMEDIATELY GET MEDICAL HELP.
INHALATION-REMOVE TO FRESH AIR AND PROVIDE CPR IF NEEDED.
* Fire Fighting Measures *
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
* Accidental Release Measures *
Spill Release Procedures:WIPE OR MOP UP AND PLACE IN A CONTAINER FOR
DISPOSAL. FLUSH RESIDUE AWAY WITH WATER.
*Handling and Storage *
Handling and Storage Precautions:DO NOT FREEZE. STORE BETWEEN 2 AND 8C.
KEEP CONTAINER TIGHTLY CLOSED. PROTECT FROM PHYSICAL DAMAGE.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. FOR THERAPEUTIC USE
ONLY.
* Physical/Chemical Properties *
HCC:N1
pH:3.0
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS SOLUTION, ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:HIGH HEAT, EXPOSURE TO LIGHT.
Hazardous Decomposition Products:TOXIC OXIDES OF NITROGEN., AND
HYDROGEN CHLORIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL,
STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST:PREFERABLE. MECHANICAL (GENERAL):ACCEPTABLE.
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:AVOID BREATHING VAPOR OR SPRAY MIST. AVOID
CONTACT WITH SKIN OR EYES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
CAGE:ACEHA
CAGE:ACEHA
* Composition/Information on Ingredients *
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
Ingred Name:CALCIUM CARBONATE
Ingred Name:BARIUM, CALCIUM, MAGNESIUM, STRONTIUM, ALUMINUM SILICATE
FLUX; (ALUMINUM SILICATE)
OSHA PEL:5 MG/CUM (MFR)
ACGIH TLV:5 MG/CUM (MFR)
Ingred Name:NEPHELINE SYENITE
Fraction by Wt: 3.1%
OSHA PEL:N/K
ACGIH TLV:5 MG/CUM (MFR)
Ingred Name:1-PROPANOL, 2-AMINO-2-METHYL-;
(2-AMINO-2-METHYL-1-PROPANOL)
Fraction by Wt: 0.2%
Fraction by Wt: <0.1%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IN A CONFINED AREA VAPORS IN
HIGH CONCNETRATION ARE ANESTHETIC, IRRITANT TO UPPER RESPIRATORY
SYSTEM. SIGNS AND SYMPTOMS OF EXPOSURE:LIGHTHEADEDNESS AND
STAGGERED GAIT. CHRONIC:PROBLEMS WITH RES PIRATORY SYSTEM MAY BE
AGGRAVATED BY EXPOSURE TO VAPORS.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:CHRONIC PROBLEMS WITH RESPIRATORY
SYSTEM MAY BE AGGRAVATED TO EXPOSURE TO VAPORS.
* First Aid Measures *
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE FROM EXPOSURE.
RESTORE BREATHING. KEEP WARM AND QUIET. SKIN:WASH WITH SOAP AND
AID. LAU NDER CONTAMINATED CLOTHING BEFORE REUSE.
* Fire Fighting Measures *
Extinguishing Media:NON-COMBUSTIBLE. FOR DRY SOLIDS USE WATER, FOAM
CO*2, DRY CHEMICALS.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS EXPOSED TO EXTREME HEAT
MAY RUPTURE DUE TO PRESSURE BUILD-UP. CONTENTS MAY SPATTER IF
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:DOL STORAGE CATEGORY 3B.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
* Physical/Chemical Properties *
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORED PIGMENTED LIQUID WITH SLIGHT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NO HAZARDOUS REACTIONS ARE EXPECTED UNDER NORMAL USE.
Stability Condition to Avoid:
Hazardous Decomposition Products:CARBON DIOXIDE AND CARBON MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS. DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS REGARDING POLLUTION.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IN DUSTY CONDITIONS, USE A SULFUR DIOXIDE/ACID
GAS CARTRIDGE RESPIRATOR W/A DUST PRE-FILTER.
Ventilation:LOCAL EXHAUST PREFERRED.
Other Protective Equipment:COVERALLS/RUBBER APRON TO PREVENT
CONTAMINATION OF CLOTHING.
Supplemental Safety and Health
PREVENT OXYGEN PITTING CORROSION OF BOILER SYSTEMS. THE CATALYST
PRESENT PERMITS MORE EFFICIENT REACTION OF SULFITE W/OXYGEN. THE D
* Product Identification *
Preparer's Name:KIRAN B JAIN, PH.D.
* Composition/Information on Ingredients *
Ingred Name:SODIUM SULFITE
Other REC Limits:5 MG/CUM (DUST)
Ingred Name:NON-HAZARDOUS INGREDIENTS
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: MAY CAUSE IRRITATION.
INHALATION: MAY CAUSE IRRITATION TO MUCOUS MEMBRANES. INGESTION:
IRRITATION TO THE STOMACH DUE TO LIBERATION OF SULFUROUS ACID.
HARMFUL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
* First Aid Measures *
WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION: DRINK A LARGE
AMOUNT OF WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point:NONE
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING & USE SELF
CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION MAY YIELD OXIDES OF
SULFUR.
* Accidental Release Measures *
Spill Release Procedures:SWEEP/SHOVEL INTO WASTE CONTAINER W/A COVER.
FLUSH RESIDUE TO WASTE W/EXCESS WATER. WEAR RECOMMENDED PROTECTIVE
CLOTHING & EQUIPMENT.
*Handling and Storage *
Handling and Storage Precautions:STORE IN SEALED CONTAINERS IN A COOL,
DRY PLACE. PROTECT CONTAINERS FROM EXTREME TEMPERATURE CONDITIONS.
AVOID CONTACT W/ACIDS & OXIDIZERS.
Other Precautions:HANDLE W/CARE. AVOID EYE & SKIN CONTACT. AVOID
BREATHING DUST/VAPORS. KEEP OUT OF REACH OF CHILDREN.
* Physical/Chemical Properties *
Spec Gravity:2.6
pH:(SUPP)
Appearance and Odor:WHITE TO LIGHT STRAW POWDER W/NO ODOR
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACIDS & STRONG OXIDIZERS
Stability Condition to Avoid:EXTREME TEMPERATURES
Hazardous Decomposition Products:THERMAL DECOMPOSITION: OXIDES OF
SULFUR. LIBERATES SULFUR DIOXIDE IN PRESENCE OF ACID.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NORMALLY REQUIRED. IF TLV EXCEEDED, WEAR
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS OR SUPPLIED-AIR
RESPIRATOR, OPERATED IN POSITIVE PRESSURE MODE.
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO MEET TLV
REQUIREMENTS.
Other Protective Equipment:EYEBATH, SAFETY SHOWER, PROTECTIVE CLOTHING
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
THIS MSDS WAS PREPARED BY THE PROFESSIONALS OF DGSC-VBA/HMIS WITHOUT
ANY WARRANTY. IT IS THE USER'S RESPONSIBILITY TO GATHER INFORMATION
AND USE THE MATERIAL PROPERLY TO PROTECT EMPLOYEES AND ENVIRONM
ENT.
* Product Identification *
Preparer's Name:DGSC-VBA/HMIS
* Composition/Information on Ingredients *
Fraction by Wt: SEE ING
Other REC Limits:NONE RECOMMENDED
Ozone Depleting Chemical:1
Ingred Name:ETHANE, 1,1-DIFLUORO
Fraction by Wt: SEE # 1%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:CARDIOVASCULAR &
PERIPHERAL NERVOUS SYSTEMS. ACUTE- IF INHALED IN CONCENTRATIONS
CAUSE FROSTBITE IF EYES OR SKIN WAS EXP OSED TO LIQUID OR SPRAY.
INGESTION IS UNLIKELY DUE TO EXISTANCE AS A GAS AT ROOM
TEMPERATURES. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYE AND/OR SKIN FROSTBITE, NARCOSIS,
ASPHYXIATION, RESPIRATORY TRACT IRRITATION, DIZZINESS, TREMORS,
UNCONSCIOUSNESS, CARDIAC ARREST
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH CARDIAC ARRHYTHMIA
OR RESPIRATORY DISORDERS MAY BE AT INCREASED RISK IN SEVERE
EXPOSURES.
* First Aid Measures *
First Aid:GET MEDICAL ATTENTION IN ALL CASES. EYE/SKIN:FLUSH WITH WATER
INHALED:REMOVE TO FRESH AIR & PROVIDE OXYGEN/CPR IF NEEDED.
ORAL:NOT APOTENTIAL ROUTE OF EXPOSURE; GET MEDICAL ATTENTION IF
NECESSARY.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CYLINDERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
Unusual Fire/Explosion Hazard:MAY FORM CORROSIVE AND TOXIC HYDROGEN
CYLINDERS MAY RUPTURE.
* Accidental Release Measures *
Spill Release Procedures:KEEP UPWIND. VENTILATE ENCLOSED SPACES UNTIL
GAS IS DISPERSSED. DO NOT SMOKE OR OPERATE INTERNAL COMBUSTION
Neutralizing Agent:NOT RELEVANT
*Handling and Storage *
Handling and Storage Precautions:STORE IN WELL-VENTILATED, DRY, COOL
MATERIALS. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:AVOID BREATHING VAPORS. AVOID EYE OR SKIN CONTACT.
WASH WITH SOAP AND WATER AFTER HANDLING AND BEFORE EATING OR
DRINKING. USE WITH ADEQUATE VENTILATION.
* Physical/Chemical Properties *
HCC:G3
NRC/State Lic Num:NOT RELEVANT
Vapor Density:>1
Spec Gravity:NOT RELEVANT
Viscosity:NOT RELEVANT
Evaporation Rate & Reference:GAS
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORLESS LIQUEFIED GAS - FAINT ETHEREAL ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CHEMICALLY ACTIVE METALS SUCH AS SODIUM, POTASSIUM, CALCIUM, POWDERED
ALUMINUM, ZINC AND MAGNESIUM
Stability Condition to Avoid:OPEN FLAME, EXTREMELY HOT/GLOWING METAL
SURFACES, HIGH TEMPERATURES
Hazardous Decomposition Products:MAY FORM HYDROGEN FLUORIDE, HYDROGEN
* Disposal Considerations *
Waste Disposal Methods:FOR DISCHARGE OR DISPOSING OF MATERIAL, CONSULT
LOCAL, STATE AND FEDERAL AUTHORITIES. DO NOT WENT TO ATMOSPHERE.
RECYLCE PRODUCT.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED DUST RESPIRATOR RECOMMENDED FOR
CONCENTRATIONS ABOVE 6 MG/M3.
Ventilation:ADEQUATE FOR DUSTY ENVIRONMENTS.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PH: 4.0 (4% AQUEOUS SLURRY). HNDLG/STOR PRECS: MATERIAL FUMED SILICA IN
THE PRESENCE OF FLAMMABLE OR EXPLOSIVE LIQUIDS, SHOULD BE TAKEN TO
* Product Identification *
Product ID:COLLOIDAL SILICA
* Composition/Information on Ingredients *
Ingred Name:SILICA, AMORPHOUS FUMED; (SILICA, AMORPHOUS, FUMED,
CRYST.-FREE)
OSHA PEL:6 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: NONE KNOWN OTHER THAN POSSIBLE
TEMPORARY DISCOMFORT DUE TO INHALATION OF DUST CONCENTRATION ABOVE
PERMISSIBLE EXPOSURE LIMIT. CHRONIC: HUMAN STUDIES HAVE FOUND
WORKPLACE EXPOSURES TO FUMED SILI CA DO NOT CAUSE CHRONIC HEALTH
EFFECTS.HOWEVER, SOME RESEARCHERS BELIEVE THAT CHRONIC
INFLAMMATION, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: LUNG FIBROSIS AND LUNG TUMORS CAN BE
DEVELOPED FROM EXPOSURE TO LEVELS OF INSOLUBLE DUST ABOVE THE
INDUSTRY STANDARD OF 6 MG/M3. THIS EXPOSURE RESULTS IN DUST
OVERLOAD PHENOMENON WHICH IS DU E TO LUNG CLEARANCE MECHANISM BEING
OVERLOADED. AMORPHOUS FUMED SILICA WAS NOT USED IN THESE RESEARCH
TESTS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INGEST: CALL MD IMMEDIATELY . SKIN: FLUSH W/COPIOUS AMOUNTS
OF WATER. CALL MD . EYES: FLUSH EYES WITH PLENTY OF WATER FOR AT
FRESH AIR.
* Fire Fighting Measures *
Extinguishing Media:NOT APPLICABLE. MEDIA SUITABLE FOR SURROUNDING FIRE
.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:SEE HANDLING/STORAGE PRECAUTIONS.
* Accidental Release Measures *
Spill Release Procedures:SPILLED PHOENIX ANTI-SAG BASE MATERIAL FUMED
SILICA IS NOT A HAZARDOUS WASTE UNDER US FEDERAL RCRA REGULATIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DRY POWDERED MATERIALS CAN BUILD
STATIC ELECTRICAL CHARGES WHEN SUBJECTED TO FRICTION. PROPER
PRECAUTIONS, WHEN USING PHOENIX ANTI-SAG BASE (SUPDAT)
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
Spec Gravity:2.2 (H*2O=1)
pH:SUPDAT
Solubility in Water:INSOLUBLE
Appearance and Odor:FINE WHITE POWDER; ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS . PHOENIX ANTI-SAG BASE MATERIAL FUMED
SILICA MAY BE SWEPT UP OR VACUUMED FOR NORMAL DISPOSAL. CONTAINER
DISPOSAL: ORDINA RY METHODS FOR NON-HAZARDOUS WASTE.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF VAPOR, MIST, OR DUST IS GENERATED, USE
NIOSH/MSHA APPROVED RESPIRATOR AS APPROPRIATE. SUPPLIED AIR
RESPIRATORY PROTECTION SHOULD BE USED FOR CLEANING LARGE SPILLS OR
UPON ENTRY INTO TANKS, VESSELS OR OTHER CONFINED SPACES.
Ventilation:LOCAL EXHAUST RECOMMENDED IF GENERATING VAPOR, DUST OR
MIST. IF VENTILATION IS INADEQUATE USE NIOSH APPROVED RESPIRATOR.
Other Protective Equipment:UNIFORMS, COVERALLS OR LAB GARMETS MUST BE
RUBBER BOOTS.
Work Hygienic Practices:LAUNDER OR DRY CLEAN WHEN SOILED. EYE WASH AND
SAFETY SHOWER SHOULD BE AVAILABLE NERBY WHEN THIS PRODUCT IS USED.
Supplemental Safety and Health
THIS PRODUCT IS INTENDED FOR USE AS A MOTOR FUEL ONLY. THIS PRODUCT IS
NOT INTENDED FOR USE IN SPACE HEATERS. DO NOY USE IN AGRICULTURAL
SPRAYS. WARNING!! THSI PRODUCT CONTAINS DETECTABLE AMOUNTS OF B
ENZENE & TOLUENE, WHICH ARE KNOWN TO THE STATE OF CALIFORNIA TO
CAUSE CANCER &/OR REPRODUCTIVE TOXICITY.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:COMPLEX MIXTURE OF HYDROCARBONS PRODUCED BY CRUDE OIL
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: EYES-MAY CAUSE IRRITATION.
SKIN-CAUSES SEVERE IRRITATION. INHALATION-VAPORS OR MIST MAY CAUSE
IRRITATION OF THE NOSE & THROAT. IN POORLY VENTILATED AREAS
UNCONSCIOUSNESS & ASPHYXIATION MAY RESU LT. INGESTION-ASPIRATION
MAY OCCUR DURING SWELLING OR VOMITING RESULTING IN LUNG DAMAGE.
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:EYES-MILD DISCOMFORT & REDNESS OF THE EYES.
SKIN-PAIN, SEVERE EXCESS REDNESS & SWELLING WITH CHEMICAL BURNS,
BLISTER FORMATION & POSSIBLE TISSUE DESTRUCTION.
INHALATION-HEADACHE, NAUSEA, VOMITING, DIZ ZINESS, DROWSINESS,
EUPHORIA, LOSS OF COORDINATION, & DISORIENTATION.
INGESTION-ABDOMINAL DISCOMFORT, NAUSEA, DIARRHEA.
Medical Cond Aggravated by Exposure:SKIN CONTACT MAY AGGRAVATE AN
EXISTING DERMATITIS (SKIN CONDITION).
* First Aid Measures *
First Aid:EYES-FLUSH EYES WITH PLENTY OF WATER. GET MEDICAL ATTENTION.
SKIN-FLUSH SKIN WITH LARGE AMOUNTS OF WATER. REMOVE CONTAMINATED
CLOTHES. INGESTION-GET IMMEDIATE MEDICAL ATTENTION. ONLY INDUCE
VOMITING A S DIRECTED BY A DOCTOR. INHALATION-REMOVE TO FRESH AIR.
IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF BREATHING
DIFFICULT, GIVE OXYGEN. GET IMMEDIATE MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:USE WATER SPRAY, DRY CHEMICAL, FOAM OR CARBON
DIOXIDE. WATER OR FOAM MAY CAUSE FROTHING. USE WATER TO COOL
CONTAINERS.
Fire Fighting Procedures:IF A LEAK OR SPILL HAS NOT IGNITED, USE WATER
SPRAY TO DISPERSE THE VAPORS AND TO PROVIDE PROTECTION FOR PERSONS
ATTEMPTING TO STOP THE LEAK.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA. AVOID BREATHING VAPORS. USE
SELF-CONTAINED BREATHING APPARATUS OR SUPPLIED AIR FOR LARGE SPILLS
OR CONFINED AREAS. CONTAIN SPILL IF POSSIBLE. WIPE OR ABSORB ON
SUITABLE MATERIAL & SHOV EL UP. PREVENT ENTRY INTO SEWERS &
WATERWAYS.
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM HEAT AND OPEN FLAME.
TRANSPORT, HANDLE, AND STORE IN ACCORDANCE WITH OSHA REGULATIONS
Other Precautions:NONE.
* Physical/Chemical Properties *
HCC:V4
Vapor Pres:LOW
Vapor Density:N.D.
pH:N.A.
Solubility in Water:NIL.
Appearance and Odor:CLEAR AND BRIGHT LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
THIS MATERIAL REACTS VIOLENTLY WITH STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC LEVELS OF CARBON MONOXIDE,
CARBON DIOXIDE, IRRITATING ALDEHYDES AND KETONES.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCODANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NEEDED IN NORMAL LABORATORY HANDLING. IF
DUSTY CONDITIONS PREVAIL, WORK IN VENTILATION HOOD OR WEAR A
NIOSH-APPROVED DUST MASK OR RESPIRATOR.
Ventilation:LOCAL EXHAUST: RECOMMENED. /MECHANICAL: RECOMMENDED.
Work Hygienic Practices:REMOVE AND WASH CONTAMINATED CLOTHING
Supplemental Safety and Health
* Product Identification *
Product ID:POTASSIUM OXALATE
Preparer's Name:MICHAEL RASZEJA
* Composition/Information on Ingredients *
Ingred Name:POTASSIUM OXALATE
* Hazards Identification *
Health Hazards Acute and Chronic:SKIN AND EYES: MAY CAUSE SEVERE EYE
AND SKIN IRRITATION. INHALATION: CAUSES SEVERE IRRITATION TO MUCOUS
MEMBRANES AND UPPER RESPIRATORY TRACT. INGESTION: HAS CAUSTIC
EFFECT ON MOUTH, ESOPHAGUS AND STO MACH. MAY CAUSE
GASTROINTESTITIS, KIDNEY AND/OR LIVER DAMAGE.
* First Aid Measures *
LIFTING UPPER & LOWER EYELIDS OCCASIONALLY. GET IMMEDIATE MEDICAL
ATTENTION. SKIN: FLUSH THOROUGHLY WITH WATER, THEN WASH WITH MILD
SOAP AND W ATER. INHALATION: REMOVE TO FRESH AIR. IF ILLNESS
DEVELOPS, GET IMMEDIATE MEDICAL ATTENTION. INGESTION: IF SWALLOWED,
IF CONSCIOUS, GIVE LARGE QUANTITIES OF MILK TO DRINK. DO NOT INDUCE
VOMITING. CALL PHYSICIAN IMMEDIATELY. NEVER GIVE ANYTHING BY MOUTH
TO AN UNCONSCIOUS PERSON.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY; CARBON DIOXIDE; DRY CHEMICAL
Fire Fighting Procedures:IN FIRE CONDITIONS, WEAR A NIOSH APPROVED
SELF-CONTAINED BREATHING APPARATUS AND PROTECTIVE CLOTHING TO
PREVENT CONTACT WITH SKIN AND EYES. AVOID INHALATION OF GASES.
Unusual Fire/Explosion Hazard:DANGEROUS WHEN HEATED TO DECOMPOSITION,
EMITS TOXIC FUMES. CAN REACT VIGOROUSLY WITH OXIDIZING MATERIALS.
* Accidental Release Measures *
Spill Release Procedures:WEAR SUITABLE PROTECTIVE CLOTHING. SWEEP UP
AND PLACE IN A SUITABLE CONTAINER FOR PROPER DISPOSAL. FLUSH SPILL
AREA WITH WATER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE AWAY FROM
FOOD PRODUCTS. WASH THOROUGHLY AFTER HANDLING.
Other Precautions:AVOID CONTACT WITH SKIN AND EYES. DO NOT TAKE
INTERNALLY. AVOID BREATHING DUST. USE WITH ADEQUATE VENTILATION.
FOR LABORATORY USE ONLY. KEEP OUT OF REACH OF CHILDREN. DO NOT WEAR
CONTACT LENSES WHEN WORKING WITH CHEMICALS. READ LABEL ON
CONTAINER BEFORE USING. NOT FOR DRUG, FOOD OR HOUSEHOLD USE.
* Physical/Chemical Properties *
HCC:T4
Boiling Pt:B.P. Text:DECOMPOSES
Melt/Freeze Pt:M.P/F.P Text:DECOMPOSES ON HEATING
Vapor Pres:NEGLIGIBLE
Vapor Density:NO DATA
Evaporation Rate & Reference:NON-VOLITILE
Appearance and Odor:COLORLESS, TRANSPARENT CRYSTALS OR POWDER; NO ODOR
Percent Volatiles by Volume:NON-VOLATILE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:EXCESSIVE TEMPERATURE AND HEAT.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY RELEASE
TOXIC FUMES OF CARBON MONOXIDE AND POTASSIUM OXIDES.
* Toxicological Information*
DUST: RESPIRATORY FRACTION - 5 MG/M3; TOTAL DUST - 1 MG/M3.
* Disposal Considerations *
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE OR LOCAL LAWS. THESE DISPOSAL GUIDE LINES ARE
INTENDED FOR CATALOG-SIZE QUANTITIES ONLY. DISPOSE OF IN AN
APPROVED INCINERATOR OR CON TRACT WITH AN APPROVED AND LICENSED
DISPOSAL AGENCY.
* MSDS Transport Information *
Transport Information:D.O.T.: TOXIC SOLID, INORGANIC, N.O.S.,
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
BY DGSC-STF.
* Product Identification *
* Composition/Information on Ingredients *
* Hazards Identification *
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
* First Aid Measures *
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
* Fire Fighting Measures *
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
* Accidental Release Measures *
*Handling and Storage *
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
* Physical/Chemical Properties *
HCC:A3
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-IN ACCORDANCE WITH
DOD REGULATIONS AND FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN XEROX
EQUIPMENT.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE REQUIRED WHEN USED AS INTENDED IN XEROX
EQUIPMENT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE
* Product Identification *
Product ID:FUSER LUBRICANT, FUSER OIL, FUSER WICK, P/N
* Composition/Information on Ingredients *
Ingred Name:POLYDIMETHYL SILOXANE
Other REC Limits: SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE MINIMAL IRRITATION OF
RESPIRATORY PASSAGES ON CONTINUOUS EXPOSURE TO HIGH CONCENTRATIONS.
Explanation of Carcinogenicity:THIS MATERIAL IS NOT A CARCINOGEN.
Effects of Overexposure: SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure: WHEN USED AS DESCRIBED BY
PRODUCT LITERATURE.
* First Aid Measures *
First Aid:EYES-FLUSH EYES RHOROUGHLY WITH WATER. SKIN-WASH WITH SOAP
AND WATER. INHALATION-REMOVE FROM EXPOSURE. INGESTION-DILUTE
STOMACH CONTENTS WITH SEVERAL GLASSES OF WATER.
* Fire Fighting Measures *
Flash Point Method:COC
Extinguishing Media:FOAM, CARBON DIOXIDE, WATER SPRAY.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:.
* Accidental Release Measures *
Spill Release Procedures:SOAP UP WITH ABSORBENT MATERIAL.
*Handling and Storage *
Handling and Storage Precautions:USE REASONABLE CARE AND CAUTION. CLEAN
UP SPILLS COMPLETELY AS RESIDUE IS SLIPPERY.
Other Precautions:
* Physical/Chemical Properties *
HCC:N1
Vapor Pres:<5
Evaporation Rate & Reference:<1 (ETHER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR LIQUID/SLIGHT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIAL.
Stability Condition to Avoid: SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:SILICONE DIOXIDE, CARBON DIOXIDE, AND
TRACES OF INCOMPLETELY BURNED CARBON PRODUCTS.
* Disposal Considerations *
Waste Disposal Methods:ABSORB LIQUID ON VERMICULITE OR OTHER ABSORBENT
MATERIAL. DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS. BIODEGRADATION/NONBIODEGRADABLE, BIOACCUMULATION/NO
EVIDENCE OF ACCUMULATI ON.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:GENERAL ROOM VENTILATION ADEQUATE.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PH: 6.5-7.2.
* Product Identification *
Preparer's Name:TERRY A. MEYERS
* Composition/Information on Ingredients *
Ingred Name:GLYCOLS, POLYETHYLENE, DODECYLETHER, MONOSULFONATE,
AMMONIUM SALT; (AMMONIUM LAURYL ETHER SULFATE)
Fraction by Wt: 1-3%
Ingred Name:WATER
Ingred Name:SULFURIC ACID, MONODECYL ESTER, AMMONIUM SALT; (AMMONIUM
LAURYL SULFATE)
Fraction by Wt: 1-3%
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY IRRITATE THE EYES, AND THE SKIN .
Explanation of Carcinogenicity:NOT RELEVANT
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE O*2/ARTF
RESP) . INGEST: CALL MD IMMED . EYES: IMMED FLUSH WITH POTABLE
FLUSH WITH COPIOUS AMOUNTS OF WATER. CALL MD .
* Fire Fighting Measures *
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NO SPECIAL HAZARDS KNOWN.
* Accidental Release Measures *
Spill Release Procedures:SWEEP OR SCRAPE UP AND CONTAINERIZE. RINSE
AFFECTED AREA THOROUGHLY WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP FROM FREEZING. KEEP OUT OF REACH
OF CHILDREN.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
pH:SUPDAT
Solubility in Water:COMPLETE
Appearance and Odor:PINK LIQUID WITH FRAGRANT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:WHEN EXPOSED TO FIRE, PRODUCES NORMAL
PRODUCTS OF COMBUSTION.
* Disposal Considerations *
Waste Disposal Methods:NO SPECIAL METH. OBSERVE ALL APPLIC FED/ST REGS
& LOCAL ORDINANCES REGARDING DISP OF NON-HAZ MATLS. WASTE FROM NORM
PROD USE MAY BE SEWERED TO A PUBLIC-OWNED TRTMT WORKS (POTW) IN
COMPLIANCE W/APPLIC FED, ST, & LOC PRETREATMENT REQUIREMENTS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CNCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV
Other Protective Equipment:RUBBER BOOTS AND APRON.
Work Hygienic Practices:WASH THROROUGHLY AFTER HANDLING.LAUNDER
CLOTHING DAILY AFTER USE.
Supplemental Safety and Health
1-HR EXPOS (ANALYTICAL).FIRST AID PROC:DOWN THROAT,REPEAT UNTIL
FLUID IS CLEAR.KEEP VICTIM FLAT & QUIET.NEVER GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS PERSON.GRT MED ATTN IMMEDIATELY.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:FENAMIPHOS(SARA III)
Other REC Limits:N/K
OSHA PEL:S, 0.1 MG/M3
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NEMACUR IS A TOXIC CHEMICAL WHICH,LIKE
OTHER ORGANOPHOSPHATE COMPOUNDS,INHABITS THE ENZYME CHOLINESTERASE
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES & SKIN:N/K . INGEST &
INHAL:NAUSEA,SWEATING,TIGHTNESS IN THE CHEST,CONSTRICTED
PUPILS,STOMACH PAINS,DIARRHEA & VOMITING,GROSSLY EXCESSIVE EXPOSURE
CAN PRODUCE SYMPTOMS OF LIFE-THREATEN ING EFFECTS SUCH AS MUSCULAR
TREMORS,UNCONTROLLED MUCOUS SECRETION,COVULSIONS SND COMA.
Medical Cond Aggravated by Exposure:N/K (N/ORNL)
* First Aid Measures *
AIR.IF NOT BRTHG.GIVE ARTF RESP,PREFERABLY MOUTH TO MOUTH.GET MED
OF SYRUP OF IPECAC.IF VOMIT DOSE.IF SYRUP NOT AVAIL.INDUCE VOMIT BY
STICKING FINGER (SEE SUPP)
* Fire Fighting Measures *
Fire Fighting Procedures:USE FIRE FIGHTING APPRVD SCBA & FULL PROT
EQUIP .COOL EXPOS CNTNR W/ H*2O.FIGHT FIRE FROM UPWIND.AVOID
Unusual Fire/Explosion Hazard:HAZARDOS DECOMPOSITION
PRODUCTS:P*2O:5,CO.SO:2CH3SH,AMINES.
* Accidental Release Measures *
Spill Release Procedures:CONTAIN SPILLED MATERIAL.CAREFULLY SWEEP UP
AND PLACE IN COVERED CONTAINER.SCRUB CONTAMINATED AREA WITH
DETERGENT AND BLEACH OR CAUSTIC SOLUTION.REPEAT AND RINSE WITH
WATER.AVOID SKIN CONTACT AND BREA THING OF DUSTS.
Neutralizing Agent:N/K
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL DRY AREA AWAY FROM
EXCESSIVE HEAT AND OPEN FLAME.STORE IN AREA DESIGNATED SPECIFICALLY
FOR PESTICIDES.
Other Precautions:DO NOT STORE NEAR ANY MATERIAL INTENDED FOR USE OR
CONSUMPTION BY HUMANS OR ANIMALS.AVOID BREATHING DUST.AVOID SKIN
CONTACT.EQUIPMENT/MATERIALS INVOLED IN PESTICIDE FIRES MAY BECOME
CONTAMINATED.
* Physical/Chemical Properties *
Decomp Temp:Decomp Text:N/K
pH:N.K
Evaporation Rate & Reference:N/K (FP N
Solubility in Water:NEGLIGIBLE (A.I.)
Appearance and Odor:GRAY-REDDISH TAN SOLID,MILD SULFUR ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS,ALKALINE MATERIAL
HYDROLYSIS.UNSTABLE IN ALKALINE MEDIA.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL.STATE AND LOCAL REGULATIONS .BURY ABSORBED AND CONTAMINATED
MATERIALS IN EPA-APPROVED LANDFILL OR BURN IN AN INCINERATOR
APPROVED FOR PESTICIDE DESTRU CTION.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED. USE NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST/MECHANICAL: OPTIONAL.
Other Protective Equipment:PROTECTIVE APRON OR COVERALLS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Preparer's Name:LEWIS GRAY
CAGE:0G4R9
CAGE:0G4R9
* Composition/Information on Ingredients *
Ingred Name:ACETIC ACID, (ETHYLENEDINITRILO)TETRA-, TETRASODIUM SALT;
(TETRASODIUM EDTA)
Ingred Name:WATER
Ingred Name:N-ALKYLDIMETHYLBENZYL AMMONIUM CHLORIDE
Fraction by Wt: 1.6%
Ingred Name:QUATERNARY AMMONIUM COMPOUNDS;
(N-ALKYLDIMETHYLETHYLBENZYLAMMONIUM CHLORIDE)
Fraction by Wt: 1.5%
Ingred Name:SODIUM CARBONATE(2:1)
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SIGNS & SYMPS OF EXPOSURE: REDNESS,
IRRITATION OF EYES/SKIN. NAUSEA OR IRRITATION OF MOUTH, THROAT, ETC
IF INGESTED. TARGET ORGANS: EYES, SKIN, MUCOUS MEMBRANES.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
* First Aid Measures *
MINUTES. REMOVE ALL CONTAMINATED CLOTHING. INGEST: DO NOT INDUCE
VOMITING. DRINK LARGE QTY OF WATER AND CONTACT A PHYSICIAN. INHAL:
REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE O*2/ARTF RESP) .
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:MOP UP. RINSE WITH DETERGENT AND WATER. LARGE
SPILLS: ABSORB WITH AN INERT, DIKE/TURN CONTAINER OVER AS
APPLICABLE.
Neutralizing Agent:
*Handling and Storage *
STORE UPRIGHT IN ORIGINAL CONTAINER ONLY, IN LOCKED STORAGE. KEEP
OUT OF REACH OF CHILDREN.
Other Precautions:
* Physical/Chemical Properties *
Evaporation Rate & Reference:1(WATER=1)
Solubility in Water:COMPLETE
Appearance and Odor:TRANSPARENT BLUE LIQUID WITH LEMON-LIME ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
DO NOT MIX WITH SOAP OR ANIONIC DETERGENTS. MIX ONLY W/WATER.
Hazardous Decomposition Products:NONE.
* Disposal Considerations *
Waste Disposal Methods:SEE PRODUCT LABEL. DISPOSE IN ACCORDANCE WITH
LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED ORGANIC VAPOR TYPE
RESPIRATOR AT HIGH VAPOR LEVELS.
Ventilation:LOCAL EXHAUST:KEEP VAPOR CONCENTRATIONS <5 MG/M3 (MIST).
Other Protective Equipment:EMERG EYE WASH & DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA .
Work Hygienic Practices:GOOD PERSONAL HYGIENE TO BE FOLLOWED AT ALL
TIMES.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:THOMAS R. DERAM
* Composition/Information on Ingredients *
Ingred Name:WATER
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM PHOSPHATE, TRIBASIC; (SODIUM TRIPOLYPHOSPHATE)
(SARA III)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:COCONUT OIL ACID DIETHANOLAMINE; (BLENDED AMIDES)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BLENDED AMIDES
OSHA PEL:N/K
ACGIH TLV:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLYOXYETHYLENE PHENOL ETHER; (ETHOXYLATED PHENYL
PHOSPHATE)
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT W/EYES WILL BE PAINFUL &
IRRITATING. PROLONGED OR REPEATED CONTACT W/SKIN MAY CAUSE
IRRITATION. VAPORS FROM HOT MATERIAL MAY BE IRRITATING. INHALATION
OF HIGH VAPOR CONCENTRATIONS MAY CAUSE NA USEA & BREATHING
DIFFICULTIES.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:EYES:SEVERE IRRITANT. SKIN:MODERATE IRRITANT.
INHAL:MAY CAUSE IRRITATION IF SPRAYED OR MISTED.
Medical Cond Aggravated by Exposure:NONE KNOWN.
* First Aid Measures *
First Aid:INGEST:CALL MD IMMEDIATELY . EYES:FLUSH W/WATER FOR AT LEAST
FRESH AIR. IF BREATHING IS STOPPED, GIVE ARTIFICIAL RESPIRATION.
* Fire Fighting Measures *
Flash Point:NONE TO BOILING
Extinguishing Media:FOAM, CARBON MONOXIDE, DRY CHEMICALS, WATER FOG OR
MIST.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . KEEP EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:NONE KNOWN.
* Accidental Release Measures *
Spill Release Procedures:ABSORB SPILL ON INERT SOLID. PREVENT SEWER,
DRAIN & WATERWAY CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY AREA. AVOID
IGNITION SOURCES. KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:AVOID SPARKS & OPEN FLAMES.
* Physical/Chemical Properties *
Vapor Density:HVR/AIR
Spec Gravity:1.1 (H*2O=1)
pH:SUPDAT
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT-YELLOW LIQUID; MILD SOAP ODOR.
Percent Volatiles by Volume:SUPDAT
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING & REDUCING AGENTS.
Hazardous Decomposition Products:OXIDES OF CARBON, SULFUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF ENGINEERING AND ADMINISTRATIVE CONTROLS OF
AIR CONTAMINANTS ARE NOT POSSIBLE, USE RESPIRATORY DEVICES APPROVED
BY NIOSH/ MSHA FOR PROTECTION AGAINST SPRAY MIST AND VAPORS.
Ventilation:LOCAL EXHAUST PREFERABLE. MECHANICAL (GENERAL) EXHAUST
ACCEPTABLE. SPECIAL VENTILATION REQUIRED TO KEEP BELOW TLV & LEL.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:REMOVE AND WASH CONTAMINATED CLOTHING, DISCARD
CONTAMINATED SHOES. WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC:CALL MD. WATER SPRAY MAY BE INEFT. WATER MAY BE USED TO
COOL CLOSED CONTAINERS TO PREVENT PRESSURE BUILD-UP AND POSSIBLE
AUTO IGNITION OR EXPLOSION WHEN EXPOSED TO EXTREME HEAT.
* Product Identification *
CAGE:ACEHA
CAGE:ACEHA
* Composition/Information on Ingredients *
Ingred Name:ETHANOL, 2-PROPOXY-; (N-PROPOXY ETHANOL). VP: 0.6
Fraction by Wt: <1%
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (MINERAL SPIRIT). VP: 2
FLASH). VP: 0.5
Fraction by Wt: 3.5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION IS ANESTHETIC. IRRITATION
OF RESPIRATORY TRACT OR NERVOUS SYSTEM DEPRESSION. HEADACHE,
DIZZINESS, NAUSEA, CONFUSION, UNCONSCIOUSNESS OR COMA. SKIN/EYE:
PRIMARY IRRITATION. REPORTS HAVE ASSO C RPTD & PRLNGD OCCUPATIONAL
OVEREXP TOSOLVENTS WITH PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL: REMOVE FROM EXPOSURE, RESTORE BREATHING, KEEP WARM AND
QUIET, CALL MD. EYES: FLUSH IMMEDIATELY WITH RUNNING WATER FOR AT
CREAM. C ALL MD IN ALL CASES. INGEST: CALL MD IMMEDIATELY .
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:0.9%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
.DURING EMER CNDTNS OVEREXP TO DECOMP PRODS MAY CAUSE HLTH HAZ.
SYMP MAY NOT BE IMMED APPARENT. (SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIPMENT, SPARKS & OPEN FLAME. HEAT MAY CAUSE PRESSURE
BUILD-UP IN CLOSED CNTNRS, WATER MAY BE USED TO COOL.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DOL STORAGE CATEGORY 2. CONTENTS ARE
COMBUSTIBLE, KEEP AWAY FROM HEAT AND OPEN FLAME. USE ONLY WITH ADEQ
VENT. USE APPRVD BONDING & GROUNDING PROC.
Other Precautions:AVOID BRTHG VAP AND SPRAY MIST. AVOID CONTACT WITH
SKIN AND EYES. KEEP CONTAINER CLOSED WHEN NOT IN USE. DO NOT
TRANSFER CONTENTS TO OTHER CONTAINERS FOR STORAGE. DO NOT TAKE
INTERNALLY. KEEP OUT OF R EACH OF CHILDREN. CONSULT NFPA CODE.
* Physical/Chemical Properties *
HCC:F4
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:HIGH TEMPERATURES, OPEN FLAME.
Hazardous Decomposition Products:BY FIRE: CO2 AND CO.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS. DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS REGARDING POLLUTION.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
* Product Identification *
Preparer's Name:R.T. RICHARDS *
* Composition/Information on Ingredients *
Ingred Name:SOLVENT-DEWAXED HEAVY PARAFFINIC PETROLEUM DISTILLATES.
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:ZINC DITHIOPHOSPHATES
Fraction by Wt: <1%
Ingred Name:FATTY ACID ESTER (1-5%)
Fraction by Wt: 2.5%
Ingred Name:METHACRYLATE POLYMER (1-5%)
Fraction by Wt: 2.5%
Ingred Name:TRIARYL PHOSPHATE
Fraction by Wt: 0.3%
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES:MINIMAL
IRRITATION;SKIN:SLIGHTLY IRRITATING WITH POSSIBLE REDNESS,EDEMA OR
DRYING OF THE SKIN;INHALATION: BELIEVED TO BE MINIMALLY IRRITATING
IF NOT IN EXCESS OF PERMISSIBLE CONCENTRATIONS. CHRONIC: NOT
DETERMINED. *
Explanation of Carcinogenicity:N/R *
Effects of Overexposure:EYES: MINIMAL IRRITATION: SKIN: SLIGHTLY
IRRITATING WITH POSSIBLE REDNESS, EDEMA OR DRYING OF THE SKIN.
INHALATION: MINIMALLY IRRITATING. *
Medical Cond Aggravated by Exposure:NONE NOTED. *
* First Aid Measures *
First Aid:INHALATION:REMOVE VICTIM TO FRESH AIR.EYES: FLUSH WITH PLENTY
OF WATER. SKIN: WASH WITH SOAP AND WATER. INGESTION: TREAT
SYMPTOMATICALLY. PRACTICALLY NON-TOXIC. *
* Fire Fighting Measures *
Flash Point Method:COC
Lower Limits:UNKNOWN *
Upper Limits:UNKNOWN *
Extinguishing Media:WATER SPRAY,DRY CHEM,FOAM, CARBON DIOXIDE. *
Fire Fighting Procedures:USE WATER TO COOL FIRE-EXPOSED CONTAINERS. IF
A LEAK OR SPILL HAS NOT IGNITED, USE WATER SPRAY TO DISPERSE THE
VAPORS AND TO PROVIDE PROTECTION TO STOP A LEAK.
Unusual Fire/Explosion Hazard:HEAT OF FIRE MAY FORM HAZARDOUS
DECOMPOSITION PRODUCTS. *
* Accidental Release Measures *
Spill Release Procedures:CONTAIN SPILL IF POSSIBLE. WIPE UP OR ABSORB
ON INERT MATERIAL. PLACE IN CLOSED DISPOSAL DRUM. *
Neutralizing Agent:NOT APPLICABLE *
*Handling and Storage *
Handling and Storage Precautions:MINIMUM FEASIBLE HANDLING TEMPERATURES
SHOULD BE MAINTAINED. PERIODS OF EXPOSURE TO HIGH TEMPERATURES
SHOULD BE MINIMIZED. AVOID WATER CONTAMINATION.
Other Precautions:NONE *
Respiratory Protection:NONE REQUIRED WITH ADEQUATE VENTILATION. *
Ventilation:GENERAL/MECHANICAL TO MAINTAIN TLV/PEL BELOW THE LIMITS. *
Other Protective Equipment:PROTECTIVE CLOTHING,EYE-WASH. *
Work Hygienic Practices:AVOID CONTACT WITH SKIN & EYES;DO NOT BREATHE
VAPORS/MIST;WASH THOROUGHLY AFTER EACH USE.DO NOT USE CONTAMINATED
CLOTHES
Supplemental Safety and Health
LAUNDERING OR DRY CLEANING SOILED WORK CLOTHING AT LEAST WEEKLY. *
* Physical/Chemical Properties *
HCC:V6
NRC/State Lic Num:N/R *
Boiling Pt:B.P. Text:UNKNOWN *
Melt/Freeze Pt:M.P/F.P Text:UNKNOWN *
Vapor Pres:UNKNOWN *
Vapor Density:UNKNOWN *
Evaporation Rate & Reference:UNKNOWN *
Solubility in Water:SLIGHT *
Appearance and Odor:CLEAR ORANGE LIQUID. PETRO-LIKE ODOR. OILY. *
Percent Volatiles by Volume:N/K *
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS *
Stability Condition to Avoid:AVOID HIGH HEAT, FLAMES, IGNITION SOURCES.
*
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
ALDEHYDES AND KETONES,COMBUSTION PRODUCTS OF NITROGEN AND SULFUR. *
* Disposal Considerations *
Waste Disposal Methods:CONSULT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE BASED ON ALL LOCAL, STATE, AND FEDERAL REGULATIONS.
CONTAMINATED PRODUCT MAY RENDER THE RESULTING MATERIAL HAZARDOUS.
PRODUCT IS NOT A RCRA HAZARDOUS WASTE IF DISCARDED IN ITS
PURCHASED FORM. *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH,MSHA APPRVD CANISTER GAS MASK OR OTHER
APPROP TY OF RESP PROT
Other Protective Equipment:USE GAUNTLET TYPE GLOES. NEOPRENE APRON &
BOOTS.
Supplemental Safety and Health
EMERG & FIRST AID:INGEST:TREAT FOR SHOCK;DO NOT INDUCE VOMITING.
HOSPITALIZE.LAVAGE (USE WATER, NOT ALCOHOL OR OILS). VAPOR
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:POTASSIUM CRESYLATE
Ingred Name:SOAP EMULSIFIER, PROPRIETARY
* Hazards Identification *
Effects of Overexposure:INH:PRLNG EXPOS TO LO CONC: G.I. DISTURE,
HDCH,DIZ,SKIN ERUPT. SKIN:WHITE WRINKLED,DELAYED PAIN
* First Aid Measures *
MIN. SKIN:REMOVE CLOTHING,WASH W/LG AMT OF WATER,CASTOR OIL OR
OLIVE OIL ALCOHOL-WATER MAY SPREAD CONTAM. INH:REMOVE TO FRESH AIR,
TREAT FOR SHOCK, HOSPITALIZE. (SEE INGEST IN SUPPDATA)
* Fire Fighting Measures *
Flash Point:NONE
* Accidental Release Measures *
Spill Release Procedures:REMOVE SPILL W/COMMERCIALLY AVAILABLE
ABSORBENT. WASH REMAINING CONTAM W/WATER & MILD ALKALINE CLEANER.
*Handling and Storage *
Handling and Storage Precautions:AVOID STORING NEAR OPEN FLAMES OR
W/STRONG OXIDIZERS & ACIDS. LOOSEN CLOSURE SLOWLY & CAUTIOUSLY UPON
OPENING DRUM.STORE IN COOL PLACE.
Other Precautions:STORE IN WELL-VENTILATED AREA. DO NOT STORE IN DIRECT
SUNLIGHT.CONTAINS METHYLENE CHLORIDE. BRTHNG VAP MAY BE HAZ TO YOUR
HLTH.WEAR PROT CLOTHING, CAN BE ABSORBED THRU SKIN.
* Physical/Chemical Properties *
Vapor Density:<1.0
Evaporation Rate & Reference:<1.0 (N BU AC)
Solubility in Water:APPRECIABLE
Appearance and Odor:YELLOWISH BROWN COLOR - CRESOL ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & OXIDIZERS
Hazardous Decomposition Products:CO, CO*2. EXPOS TO FLAME OR VERY HOT
SURFACE - POSS PHOSGENE
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IAW FED, STATE & LOCAL CODES GOVERNING
DISPOSAL OF CRESOLS & SOLVENTS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHERE REQUIRED, USE ONLY NIOSH/MSHA APPROVED
Ventilation:DILUTION/LOCAL EXHAUST TO PREVENT BUILD-UP OF VAPORS. USE
EXPLOSION PROOF NON-SPARKING EQUIPMENT.
Other Protective Equipment:EYE WASH, SAFETY SHOWER, IMPERVIOUS
CLOTHING, APRON, BOOTS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. REMOVE/DISPOSE OF CONTAMINATED SHOES. WASH THOROUGHLY AFTER
HANDLING.
Supplemental Safety and Health
HEALTH HAZ CONT'D: INGESTION: LUNG DAMAGE DUE TO ASPIRATION INTO
LUNGS/MOUTH-THROAT-MUCOUS MEMBRANE IRRITANT/CNS
DEPRESSION/ANESTHETIC EFFECT/ABNORMAL BLOOD PRESSURE/LIVER-KIDNEY
DAMAGE/PULMONARY EDEM A/BLINDNESS/PARALYSIS/DEATH. FIRE HAZ CONT'D:
VAPORS >AIR/MAY TRAVEL TO DISTANT IGNITION SOURCE & FLASHBACK.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:TITANIUM DIOXIDE, TIO2 (SUSPECTED ANIMAL CARCINOGEN, IARC
Fraction by Wt: 1-5%
Ingred Name:ALKYD RESIN
Ingred Name:HYDROCARBON PROPELLANT, PETROLEUM GASES LIQUIFIED
Ingred Name:2-BUTANONE (METHYL ETHYL KETONE) (MEK)
Fraction by Wt: 1-5%
Ingred Name:ETHANOL (ETHYL ALCOHOL), TECSOL, ALCOHOL
Ingred Name:ETHYL 3-ETHOXYPROPIONATE, PROPANOIC ACID, 3-ETHOXY-, ETHYL
ESTER
Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY TRACT & MUCOUS
MEMBRANE IRRITANT/CNS DEPRESSION/RESPIRATORY PROBLEMS/ANESTHETIC
EFFECTS/BRONCHITIS/ABNORMAL BLOOD PRESSURE/LIVER-KIDNEY
DAMAGE/PNEUMOCONIOSIS/RESPIRATORY FAILUR E/ASPHYXIATION/DEATH.
SKIN: IRRITANT/DERMATITIS/ABSORPTION. EYES:
IRRITANT/CONJUNCTIVITIS/CORNEAL INJURY/BLINDNESS(SUPP)
Effects of Overexposure:IRRITATION/LOSS OF
APPETITE/FATIGUE/DROWSINESS/DIZZINESS/LIGHTHEADEDNESS/HEADACHE/UNCO
ORDINATION/NAUSEA/VOMITING/DIARRHEA/CHEST PAIN/BLURRED
VISION/FLU-LIKE SYMPTOMS/COUGHING/SNEEZING/DIFFICULTY BREAT
HING/FEVER/CHILLS/TREMORS/CONVULSIONS/LOSS OF
CONSCIOUSNESS/ASPHYXIATION/DEFATTING/BLISTERING/TEARING/REDNESS/NAR
COSIS.
Medical Cond Aggravated by Exposure:EYE, SKIN, RESPIRATORY & LUNG
DISORDERS. ASTHMA-LIKE CONDITIONS, KIDNEY/LIVER/NERVOUS SYSTEM
DISORDERS.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED
BREATHING. HAVE TRAINED PERSON GIVE OXYGEN. SKIN: FLUSH W/WATER,
THEN WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH IMMEDIATELY
ALL CASES.
* Fire Fighting Measures *
Flash Point:1F
Extinguishing Media:DRY CHEMICAL/FOAM, WATER FOG, CO2
Fire Fighting Procedures:WATER MAY BE USED TO COOL/PROTECT EXPOSED
CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE/BURST WHEN
EXPOSED TO EXTREME HEAT/FIRE. VAPORS MAY EXPLODE AT AMBIENT
TEMPS/FORM EXPLOSIVE MIXTURES W/AIR AT ELEVATED TEMPS.(SUPP
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE IGNITION SOURCES. VENTILATE
W/EXPLOSION-PROOF EQUIPMENT/EVACUATE AREA. COLLECT W/ABSORBENT, USE
NON-SPARKING TOOLS. PLACE IN PROPER CONTAINER. SHOUT OFF LEAK
SAFELY. DIKE/CONTAIN/PUMP TO STO RAGE/SALVAGE VESSELS.
*Handling and Storage *
CLOSED/UPRIGHT WHEN NOT IN USE & AWAY FROM IGNITION SOURCES. USE
W/ADEQUATE VENTILATION. DON'T TAKE INTERNALLY.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID
CONTACT/SKIN/EYES & BREATHING VAPORS. AVOID CONDITIONS WHICH FORMS
INHALABLE PARTICLES. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING & INHALING THE CONTENTS MA Y BE HARMFUL/FATAL.
* Physical/Chemical Properties *
Appearance and Odor:FEDERAL GRAY
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS/ACIDS/REDUCING AGENTS/BASES/ALDEHYDES/ALKYL
HALIDES/ISOCYANATES/HALOGENS/AMINES/METALS/SALTS
Stability Condition to Avoid:ELEVATED TEMPS, MOISTURE, HEAT, SPARKS,
OPEN FLAME & OTHER IGNITION SOURCES
Hazardous Decomposition Products:CO/CO2/OXIDES OF NITROGEN/OXIDES OF
SULFUR/OXYGEN/HYDROGEN/CHLORIDE/ALDEHYDES/TOXIC GASES/BARIUM
COMPOUNDS/SMOKE/SOOT.
* Disposal Considerations *
Waste Disposal Methods:AVOID DISCHARGE TO SEWERS/NATURAL WATERS.
DISPOSE OF IAW/LOCAL, STATE & FEDERAL REGULATIONS. EMPTY CONTAINERS
MAY CONTAIN HAZARDOUS RESIDUES. GROUND EQUIPMENT WHEN TRANSFERRING
TO PREVENT ACCUMULATION OF STATIC CHARGE.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SELF-CONTAINED BREATHING APPARATUS - USE IN
STRICT ACCORDANCE W/THE MANUFACTURER'S RECOMMENDATIONS.
Ventilation:FRESH AIR LOCAL EXHAUST/MECHANICAL
Other Protective Equipment:SAFETY SHOES, HARD HATS & EAR PROTECTION
SHOULD BE WORN WHEN WORKING W/PRESSURIZED CARBON DIOXIDE.
Work Hygienic Practices:PERSONS HANDLING CARBON DIOXIDE SHOULD BE FULLY
TRAINED IN ADVANCE.
Supplemental Safety and Health
USE A PROPER PRESSURE REDUCING REGULATOR WHEN CONNECTING CYLINDER TO
DISCHARGE RATE. KEEP CYLINDERS UPRIGHT AND PROPERLY SECURED IN
SECURED AREAS AWAY FROM HIGH TRAFFIC. HAVE ONLY QUALIFIED
PERSONNEL REFILL CYLINDERS.
* Product Identification *
Product ID:CARBON DIOXIDE
* Composition/Information on Ingredients *
Ingred Name:CARBON DIOXIDE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SIMPLE ASPHYXIANT.HIGH CONCENTRATIONS
OF CARBON DIOXIDE IN THE AMBIENT AIR CAN REDUCE THE OXYGEN CONTENT
NECESSARY TO SUPPORT LIFE.IN THE SOLID PHASE(DRY ICE) CONTACT
W/BODY TISSUE WILL PRODUCE COLD BURNS OR FROSTBITE W/IN SEVERAL
SECONDS.
Explanation of Carcinogenicity:THIS MATERIAL IS NOT LISTED AS A
CARCINOGEN BY NTP, IARC, OSHA.
Effects of Overexposure:SHORTNESS OF
BREATH,HEADACHE,DIZZINESS,WEAKNESS,DROWSINESS & RINGING IN EARS.DRY
ICE IN CONTACT W/BODY TISSUE PRODUCES BURNING SENSATION;& FROSTBITE
OCCURS W/IN SEVERAL SECONDS.
Medical Cond Aggravated by Exposure:CONDITIONS WHICH CAUSE BREATHING
DIFFICULTY.
* First Aid Measures *
First Aid:DO NOT ATTEMPT TO REMOVE AN INDIVIDUAL FROM THE SCENE W/OUT
UTILIZING PROPER RESCUE EQUIPMENT OR YOU MAY BECOME A CASUALTY.
MOVE VICTIM TO FRESH AIR WHILE KEEPING THEM WARM, DRY & QUIET. IF
BREATHING HAS STOPPED PERFORM ARTIFICIAL RESPIRATION. GET
IMMEDIATE MEDICAL ATTENTION.
* Fire Fighting Measures *
Extinguishing Media:MATERIAL IS AN EXTINGUISHING AGENT ITSELF
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard:CONFINEMENT OF CARBON DIOXIDE IN VESSELS
CONTAINERS OF IMPROPER DESIGN CAN RESULT IN EXPLOSION OR RUPTURE
FROM OVER-PRESSURIZATION.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE THE AREA OF THE SPILL OR RELEASE,
EMPLOY EMERGENCY FIRST AID PROCEDURES,PROVIDE PLENTY OF FRESH
AIR.REMOV DRY ICE RESIDUAL & ALLOW TO SUBLIME IN A SECURED,
WELL-VENTILATED AREA & CONTACT THEMANUFACTURER'S SAFETY
DEPARTMENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:LIQUID & VAPOR STORAGE CONTAINERS ARE
UNDER HIGH PRESSURE.DO NOT MIS-HANDLE OR ABUSE,CNTS.USE ONLY
EQUIPMENT DESIGNED FOR CARBON DIOXIDE.
Other Precautions:AVOID DIRECT SKIN CONTACT WITH DRY ICE OR VENTING
CARBON DIOXIDE LIQ OR VAPOR.USE PROTECTIVE EQUIP & CLOTHING AND GET
PROPER TRAINING BEFORE HANDLING CARBON DIOXIDE IN CYLINDERS.
* Physical/Chemical Properties *
HCC:G3
Melt/Freeze Pt:M.P/F.P Text:NA
Solubility in Water:VERY SOLUBLE
Appearance and Odor:IN SOLID TRANSLUCENT WHITE & ODORLESS.IN GAS & LIQ
COLORLESS & ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACTIVE ALKALI METALS, ORGANOMETALLIC REAGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
DECOMPOSITION OF CARBON MONOXIDE & OXYGEN.
Conditions to Avoid Polymerization:IT CAUSES VIOLENT POLYMERIZATION OF
ACRYLALDEHYDE OR ETHLENEIMINE.
* Disposal Considerations *
Waste Disposal Methods:ALLOW CARBON DIOXIDE TO RELEASE, SUBLIME OR
DISSIPATE IN THE OPEN AIR.AVOID RELEASING IN COURTYARDS OR INDOORS
OR ANY AREAS WHERE HEAVY CARBON DIOXIDE VAPORS CAN ACCUMULATE.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF ENGINEERING CONTROLS ARE INADEQUATE TO
CONTROL VAPOR CONCENTRATIONS TO AN ACCEPTABLE LEVEL, A
NIOSH-APPROVED ORGANIC VAPOR RESPIRATOR SHOULD BE WORN. IN
EMERGENCY, WEAR NIOSH APPROVED SELF CONTAINE D BREATHING APPARATUS.
Ventilation:MECHANICAL (GENERAL AND/OR LOCAL EXHAUST, EXPLOSION-PROOF)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
KEY1:F3. THIS PRODUCT IS A KIT CONSISTING OF TWO PARTS: ADHESIVE (PNI
A) AND ACTIVATOR (PNI B), SAME NSN.
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:3,5-DIETYL-1,2-DIHYDRO-1-PHENYL-2-PROPYLPYRIDINE
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, CNS, LIVER,
KIDNEY, LUNG. ACUTE- MAY CAUSE EYE IRRITATION. CAN BE ABSORBED
THROUGH SKIN. INHALATION MAY CAUSE CNS EFFECTS, LUNG DAMAGE, BLOOD
IN URINE. INGESTION MAY CAUSE CNS EFFECTS, LIVER & KIDNEY CHANGES.
CHRONIC- MAY CAUSE INFLAMMATION OF NASAL CAVITY, BODY WEIGHT LOSS &
KIDNEY CHANGES.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, TEARING, BLURRED VISION, HEADACHE,
DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, VOMITING, DIARRHEA,
CONFUSION, DIFFICULTY IN BREATHING, INCOORDINATION
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING
DISEASES OF THE EYE, SKIN, RESPIRATORY TRACT, LIVER, KIDNEYS, CNS
MAY HAVE INCREASED SUSCEPTIBILITY TO THE TOXICITY OF EXCESSIVE
EXPOSURES.
* First Aid Measures *
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP & WATER. ORAL:DO
NOT IN DUCE VOMITING. IF CONSCIOUS, DRINK TWO GLASSES OF WATER TO
DILUTE. SEEK IMMEDIATE MEDICAL ATTENTION. IF SPONTANEOUS VOMITING
OCCURS, KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION OF VOMITUS INTO
LUNGS.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:2.1
Extinguishing Media:USE CARBON DIOXIDE, SAND, FOAM/DRY CHEMICAL. WATER
SPRAY MAY BE USED TO KEEP FIRE EXPOSED CONTAINERS COOL.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:VAPOR IS HEAVIER THAN AIR AND CAN TRAVEL
CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK.
CONTAINERS MAY RUPTURE DUE TO VAPOR PRESSURE BUILDUP.
* Accidental Release Measures *
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. CONTAIN SPILL. PICK UP SPILL WITH
NON-SPARKING PUMP OR NON-FLAMMABLE ABSORBENT SUCH AS SAND. PLACE IN
CONTAINER FOR DISPOSAL. PREVENT LIQUID FROM ENTERING SEWERS,
WATERWAYS.
Neutralizing Agent:NOT RELEVANT
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, VENTILATED AREA AWAY
FROM SOURCES OF IGNITION & INCOMPATIBLE MATERIALS. BOND AND GROUND
CONTAINERS WHEN TRANSFERRING LIQUID.
Other Precautions:EXTEMELY FLAMMABLE. "EMPTY" CONTAINERS MAY RETAIN
RESIDUE AND CAN BE DANGEROUS. FOLLOW ALL LABEL INSTRUCTIONS. KEEP
OUT OF REACH OF CHILDREN. AVOID BREATHING VAPORS. DO NOT GET IN
* Physical/Chemical Properties *
HCC:F3
NRC/State Lic Num:NOT RELEVANT
Decomp Temp:Decomp Text:NOT KNOWN
Vapor Density:3.5
Evaporation Rate & Reference:3 (N-BUTYL ACETATE=1)
Appearance and Odor:PASTE WITH VARIED FRAGRANT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG BASES, STRONG ACIDS, PAINT, RUBBER,
STRONG REDUCING AGENTS
Stability Condition to Avoid:HIGH HEAT, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:SMOKE, CARBON MONOXIDE, CARBON
DIOXIDE, OXIDES OF NITROGEN, CYANIDE MAY BE FORMED.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL ENVIRONMENTAL REGULATIONS.
INCINERATION IS THE PREFERRED METHOD OF DISPOSAL. THE RCRA CODE FOR
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT REQUIRED, UNDER NORMAL PRODUCT USE.
Ventilation:USE W/ADEQUATE VENTILATION.
Other Protective Equipment:CHEMICAL RESISTANT APRON, PROTECTIVE
CLOTHING.
Work Hygienic Practices:GOOD HYGIENE PRACTICES SHOULD BE FOLLOWED TO
AVOID EYE & SKIN CONTACT W/THIS PRODUCT.
Supplemental Safety and Health
WHILE THE PRODUCTS LISTED ARE NOT CONSIDERED HAZARDOUS AS DEFINED BY
OSHA, BCA WOULD LIKE TO MAKE YOU AWARE OF THE FOLLOWING HANDLING
PRECAUTIONS: THESE PRODUCTS CONTAIN 0.1%/LESS SODIUM AZIDE AS A PR
ESERVATIVE. THEREFORE, WE HAVE ENCLOSEDA MSDS FOR 0.1% SODIUM
AZIDE.
* Product Identification *
* Composition/Information on Ingredients *
Fraction by Wt: 0.1%
Other REC Limits:0.1 PPM
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF SWALLOWED. MAY BE ABSORBED
THROUGH SKIN. MAY CAUSE ALLERGENIC REACTION IN SUSCEPTIBLE
INDIVIDUALS.
Explanation of Carcinogenicity:NONE
* First Aid Measures *
NECESSARY. INGESTION: FLUSH MOUTH. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:DRY CHEMICAL/CO2
* Accidental Release Measures *
Spill Release Procedures:SMALL: WEAR PROTECTIVE CLOTHING TO GUARD
AGAINST EYE & SKIN CONTACT. USE SPILL PILLOWS/OTHER APPROPRIATE
ABSORBENT. PLACE MATERIALS IN SEALED CONTAINER FOR PROPER DISPOSAL.
*Handling and Storage *
NEAR ACIDS.
* Physical/Chemical Properties *
Vapor Pres:AS WATER
Evaporation Rate & Reference:(WATER=1): 1
Appearance and Odor:COLORLESS LIQUID W/NO ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACIDS
Hazardous Decomposition Products:TOXIC GAS, MAY FORM EXPLOSIVE
LEAD/COPPER IN LABORATORY PLUMBING
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS. MAY FORM EXPLOSIVE LEAD/COPPER AZIDE IN
LABORATORY PLUMBING.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE A NIOSH-APPROVED RESPIRATOR FOR ACID MISTS
WHEN HANDLING SPILLS, LEAKS OR WHEN AIRBORNE CONCENTRATIONS EXCEED
EXPOSURE LIMITS.
Ventilation:PROVIDE SUFFICIENT GENERAL OR LOCAL EXHAUST VENTILATION TO
CONTROL INHALATION EXPOSURES BELOW OSHA'S PEL.
Other Protective Equipment:EYE WASH STATION & EMERGENCY SHOWER SHOULD
BE IN CLOSE PROXIMITY. USE OF RUBBERIZED COVERALLS & RUBBER SHOES
SUGGESTED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
* Product Identification *
CAGE:PURIT
CAGE:PURIT
* Composition/Information on Ingredients *
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
Ingred Name:WATER
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: EYES, SKIN, RESPIRATORY
& GI TRACTS. ACUTE- CORROSIVE. EYE OR SKIN CONTACT MAY CAUSE
CHEMICAL BURNS. MAY CAUSE PERMANENT EYE DAMAGE. INHALING MIST MAY
CAUSE SEVERE RESPIRATORY IRRITATIO N & BURNS. INGESTION MAY CAUSE
TISSUE DAMAGE & BURNS TO MOUTH, THROAT & DIGESTIVE TRACT. CHRONIC-
UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SEVERE IRRITATION, BURNS, DIFFICULTY IN
BREATHING, PAIN, NAUSEA, VOMITING, COUGHING, BLINDNESS
Medical Cond Aggravated by Exposure:SKIN IRRITATION MAY BE AGGRAVATED
IN PERSONS WITH EXISTING SKIN LESIONS. MISTS MAY AGGRAVATE ACUTE OR
CHRONIC ASTHMA OR OTHER RESPIRATORY DISEASES.
* First Aid Measures *
First Aid:GET MEDICAL ATTENTION IMMEDIATELY. EYE/SKIN: IMMEDIATELY
INHALED: REMOVE TO FRESH AIR. PROVIDE OXYGEN/CPR IF NEEDED. ORAL:
DO NOT INDUCE VO MITING. RINSE OUT MOUTH WITH WATER. DRINK LARGE
AMOUNT OF WATER. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON.
* Fire Fighting Measures *
Flash Point:NONE
Lower Limits:NOT RELEVANT
Upper Limits:NOT RELEVANT
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT SUCH
FULL-FACE SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:MAY FORM HAZARDOUS GASES SUCH AS
PHOSPHORUS OXIDES.
* Accidental Release Measures *
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENTS. DIKE SPILL WITH
SAND OR CLAY TO KEEP IT OUT OF SEWER SYSTEM. COVER WITH HYDRATED
LIME OR SODA ASH. REQUIRES GOOD VENTILATION AS CO2 IS PRODUCED.
IF > RQ.
Neutralizing Agent:SODA ASH, LIME
*Handling and Storage *
Handling and Storage Precautions:STORE IN DRY PLACE, IN CLOSED
CONTAINERS AWAY FROM INCOMPATIBLE MATERIALS.
Other Precautions:DANGER! CORROSIVE. KEEP OUT OF REACH OF CHILDREN. DO
NOT GET IN EYES, ON SKIN OR ON CLOTHING. AVOID BREATHING MISTS.
WASH THOROUGHLY AFTER HANDLING. DO NOT INGEST. READ LABEL
INSTRUCTIONS CAREFULLY.
* Physical/Chemical Properties *
HCC:C1
NRC/State Lic Num:NOT RELEVANT
Vapor Density:3.4
pH:1.5
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS, SYRUPY LIQUID - ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, SOME METALS SUCH AS ALUMINUM, ZINC, IRON, SODIUM
TETRAHYDROBORATE, ALDEHYDES, AMINES, AMIDES, ALCOHOLS
Stability Condition to Avoid:STABLE UNDER NORMAL CONDITIONS OF
HANDLING.
Hazardous Decomposition Products:TOXIC FUMES OF PHOSPHORUS OXIDES MAY
BE FORMED.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF WASTE AT AN APPROPRIATE WASTE
DISPOSAL FACILITY IN ACCORDANCE WITH APPLICABLE FEDERAL, STATE AND
LOCAL LAWS AND REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:AS REQUIRED FOR TASK & LOCATION AT HAND
Ventilation:USE LOCAL EXHAUST & MAINTAIN GOOD AIR QUALITY
Other Protective Equipment:MFR LISTS NONE
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:TIN
OSHA PEL:2 MG/M3
Ingred Name:LEAD (SARA III)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Fraction by Wt: 2.0%
ACGIH TLV:0.1 MG/CUM
ACGIH TLV:UNK
* Hazards Identification *
Effects of Overexposure:MFR PRESENTS NONE; FLUX: CAN CAUSE IRRITATION
OF SKIN & MUCOUS MEMBRANE.
* First Aid Measures *
First Aid:REMOVE VICTIM FROM CONTAMINATED AREA & KEEP WARM & QUIET IN
FRESH AIR; SKIN: WASH AFFECTED AREA W/SOAP & WATER.
* Fire Fighting Measures *
Extinguishing Media:MFR ENTERED NIL; FOR FLUX: CO*2, DRY CHEMICAL
Fire Fighting Procedures:MFR LIST NONE;
Unusual Fire/Explosion Hazard:MFR LISTS NONE; IN FIRE, MATERIAL COULD
GWIT TOXIC & CORROSIVE FUMES.
* Accidental Release Measures *
Spill Release Procedures:MFR LISTS NOTHING; FLUX MAY BE WIPED FROM A
SURFACE WITH ISOPROPYL ALCOHOL & H SPONGE.
*Handling and Storage *
Handling and Storage Precautions:USE WITH ADEQUATE LOCAL VENTILATION;
Other Precautions:DO NOT INGEST; WASH AFTER USING; DO NOT BREATHE
FUMES.
* Physical/Chemical Properties *
HCC:N1
Spec Gravity:8.5
Solubility in Water:NONE
Appearance and Odor:ALLOY: DULL SILVER; FLUX:AMBER; WIRE W/ROSIN
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
MFR LISTS NOTHING
Stability Condition to Avoid:MFR LISTS NOTHING
Hazardous Decomposition Products:FUMES MAY CONTAIN ACIDS AMINES, &
METALS
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW APPROPRIATE FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST.
Supplemental Safety and Health
WASTE DISP METH:OR HAZ WASTE REPRESENTATIVE AT NEAREST EPA REGIONAL
OFFICE FOR GUIDANCE. CONTR DISP:TRIPLE RINSE (OR EQUIVALENT). THEN
OFFER FOR RECYCLING/RECONDITIONING/PUNCTURE & DISP OF IN SANITARY
LANDFILL/BY INCIN/IF ALLOWED BY FED, STATE & LOC AUTHORITITES, BY
BURNING. IF BURNED, STAY OUT OF SMOKE. DO NOT (ING 5)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:2-BUTANONE,
1-(4-CHLOROPHENOXY)-3,3-DIMETHYL-1-(1,2,4-TRIAZOL-1-YL)-;(BAYLENTON
; TRIADIMEFON)
Ingred Name:DISULFIDE, BIS(DIMETHYLTHIOCARBAMOLYL);
(TETRAMETHYLTHIURAM) (THIRAM))
OSHA PEL:5 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:INERT INGREDIENTS (TYPE NOT SPECIFIED)
Ingred Name:SUPDAT:REUSE EMPTY CONTAINERS. DISPOSAL MUST BE I/A/W
LOCAL, STATE AND FEDERAL REGULATIONS .
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF SWALLOWED. AVOID
CONSUMPTION OF ALCOHOLIC BEVERAGES WHEN USING THIS PRODUCT. CAUSES
EYE IRRITATION. MAY BE IRRITATING TO SKIN. AVOID CONTACT WITH SKIN,
EYES OR CLOTHING.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
O2/ARTIFICIAL RESPIRATION) . EYES:FLUSH WITH PLENTY OF WATER FOR AT
MEDICAL ATTE NTION IF IRRITATION PERSISTS. INGEST:DRINK 1 OR 2
GLASSES OF WATER AND INDUCE VOMITING BY PLACING FINGER IN BACK OF
THROAT.
* Fire Fighting Measures *
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN
* Accidental Release Measures *
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, CLEAN, DRY PLACE. DO
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:T5
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITISH TAN AQUEOUS LIQUID WITH PUNGENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:NOT DEFINED
* Disposal Considerations *
Waste Disposal Methods:PESTICIDE DISP:PESTICIDE WASTES ARE TOX.
IMPROPER DISP OF EXCESS PESTICIDE, SPRAY MIX/RINSATE IS A VIOLATION
OF FED LAW. IF THESE WASTES CANNOT BE DISP OF BY USE ACCORD TO LBL
INSTRUCTIONS, CONTACT YO UR STATE PESTICIDE/ENVIRON CONTROL
AGENCY,(SUPDAT)
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT ORDINARILY REQUIRED.
Ventilation:NO DATA PROVIDED BY RESPONSIBLE PARTY.
AS NEEDED TO MINIMIZE SKIN CONTACT.
Work Hygienic Practices:GOOD PRACTICE REQUIRES THAT GROSS AMOUNT OF ANY
CHEMICAL BE REMOVED FROM THE SKIN AS SOON AS PRACTICAL.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:KAREN G. HAYNES
CAGE:0PGK2
CAGE:0PGK2
CAGE:0PGK2
* Composition/Information on Ingredients *
Ingred Name:DISTILLATES (PETROLEUM), HYDROTREATED MIDDLE OR SOLVENT
REFINED, HYDROTREATED MIDDLE DISTILLATE
Ingred Name:DISTILLATES (PETROLEUM), HYDROTREATED LIGHT NAPHTHENIC OR
SOLVENT REFINED, HYDROTREATED LIGHT NAPHTHENIC DISTILLATE
Ingred Name:DISTILLATES (PETROLEUM), SOLVENT-DEWAXED LIGHT PARAFFINIC
OR SOLVENT REFINED, HYDROTREATED LIGHT PARAFFINC DISTILLATE
Ingred Name:CALCIUM HYDROXYSTEARATE
Ingred Name:OTHER COMPONENTS
< Wt:2.
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE - EYE CONTACT: PRODUCT MAY BE
MILDLY IRRITATING TO THE EYES. SKIN CONTACT: PROLONGED OR REPEATED
CONTACT MAY CAUSE VARIOUS DISORDERS SUCH AS DERMATITIS,
FOLLICULITIS OR OIL ACNE. RELEASE DURING HIGH PRESSURE USAGE MAY
RESULT IN INJECTION OF GREASE INTO THE SKIN CAUSING LOCAL NECROSIS.
INHALATION: NOT EXPECTED TO BE A RELEVANT ROUTE OF EXPOSURE;
HOWEVER, UNDER HIGH TEMPERATURE CONDITIONS, VAP ORS IRRITATING TO
NOSE, THROAT AND UPPER RESPIRATORY TRACT MAY BE PRODUCED.
INGESTION: GREASES ARE GENERALLY CONSIDERED TO HAVE A LOW ORDER OF
TOXICITY.
Explanation of Carcinogenicity:THIS PRODUCT AND ITS COMPONENTS ARE NOT
CLASSIFIED AS CARCINOGENS BY INTERNATIONAL AGENCY FOR RESEARCH ON
CANCER (IARC), NATIONAL TOXICOLOGY PROGRAM (NTP) OR OCCUPATIONAL
SAFETY AND HEALTH ADMINISTRAT ION (OSHA).
Effects of Overexposure:IRRITATION, LOCAL NECROSIS IS EVIDENCED BY
DELAYED ONSET OF PAIN AND TISSUE DAMAGE A FEW HOURS FOLLOWING
INJECTION.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS MAY BE
AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
* First Aid Measures *
EYELIDS OPEN. GET MEDICAL ATTENTION. SKIN CONTACT: REMOVE
CONTAMINATED CLOTHING AND WIPE EXCESS OFF. WASH SKIN WITH SOAP AND
WATER OR A WATER LESS HAND CLEANER FOLLWED BY SOAP AND WATER. IF
INJECTED UNDER THE SKIN, GET MEDICAL ATTENTION PROMPTLY TO PREVENT
SERIOUS DAMAGE. DO NOT WAIT FOR SYMPTOMS TO DEVELOP. INHALATION:
REMOVE VICTIM TO FRE SH AIR AND PROVIDE OXYGEN IF BREATHING IS
DIFFICULT. GET MEDICAL ATTENTION.INGESTION: DO NOT INDUCE
VOMITING. IN GENERAL, NO TREATMENT IS NECESSARY UNLESS LARGE
QUANTITIES OF PRODUCT ARE INGESTED. HOWEVER, GET MEDICAL
ATTENTION.
* Fire Fighting Measures *
Flash Point Method:PMCC
BASE OIL
Lower Limits:N/AV
Upper Limits:N/AV
Extinguishing Media:USE WATER FOG, DRY CHEMICAL OR CARBON DIOXIDE
(CO2). DO NOT USE A DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND
CAN BE REIGNITED ON SURFACE OF WATER.
Fire Fighting Procedures:DO NOT ENTER CONFINED FIRE SPACE WITHOUT
PROPER PROTECTIVE EQUIPMENT INCLUDING A NIOSH APPROVED
SELF-COCNTAINED BREATHING APPARATUS. COOL FIRE EXPOSED CONTAINERS
SUROUNDING EQUIPMENT AND STRUCTURES WI TH WATER.
Unusual Fire/Explosion Hazard:NONE IDENTIFIED.
* Accidental Release Measures *
Spill Release Procedures:SCOOP UP EXCESS GREASE. CLEAN AREA WITH
APPROPRIATE CLEANER. MATERIAL WILL NOT BURN UNLESS PREHEATED. DO
NOT ENTER CONFINED SPACE WITHOUT FULL BUNKER GEAR (HELMET WITH
FACESHIELD, BUNKER COATS, GLOVS AND RUBBER BOOTS), INCLUDING A
POSITIVE-PRESSURE, NIOSH-APPROVED SELF-CONTAINED BREATHING
APPARATUS. COOL FIRE EXPOSED CONTAINERS WITH WATER.
Neutralizing Agent:NO DATA PROVIDED BY RESPONSIBLE PARTY.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP AWAY FROM OPEN FLAMES AND HIGH
TEMPERATURES.
Other Precautions:MINIMIZE SKIN CONTACT. WASH THOROUGHLY WITH SOAP AND
WATER AFTER HANDLING AND BEFORE EATING, DRINKING, APPLYING COSMETIC
OR USING TOILET FACILITIES. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. PROPERL Y DISPOSE OF CONTAMINATED LEATHER ARTICLES INCLUDING
SHOES THAT CANNOT BE DECONTAMINATED. KEEP OUT O F REACH OF
CHILDREN.
* Physical/Chemical Properties *
HCC:V6
Boiling Pt:B.P. Text:NOT AVAILABLE
M.P/F.P Text:DROP POINT
Vapor Pres:NOT AVAILABLE
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TAN, SMOOTH, SLIGHT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID HEAT, OPEN FLAME.
Hazardous Decomposition Products:DEPENDS HIGHLY ON THE COMBUSTION
CONDITION. A COMPLEX MIXTURE OF AIRBORNE SOLID, LIQUID,
PARTICULATES AND GASES WILL EVOLVE. CARBON MONOXIDE AND
UNIDENTIFIED ORGANIC COMPOUNDS MAY BE FORMED.
Conditions to Avoid Polymerization:HAZARDOUS POLYMERIZATION WILL NOT
OCCUR.
* Toxicological Information*
Toxicological Information:THIS SPECIFIC PRODUCT HAS NOT BEEN TESTED IN
LONG-TERM, CHRONIC EXPOSURE TESTS. LUBRICATING GREASES ARE
GENERALLY CONSIDERED TO BE OF A LOW ORDER OF ACUTETOXICITY TO
HUMANS AND EXPERIMENTAL ANIMALS.
* Ecological Information *
Ecological:NO DATA PROVIDED BY RESPONSIBLE PARTY.
* Disposal Considerations *
Waste Disposal Methods:IF THIS PRODUCT BECOMES A WASTE, IT WOULD NOT BE
APPROPRIATE DISPOSAL FACILITY IN COMPLIANCE WITH LOCAL REGULATIONS.
* MSDS Transport Information *
Transport Information:NOT HAZARDOUS BY DOT REGULATIONS. DOT PROPER
SHIPPING NAME: NOT APPLICABLE. OTHER REQUIREMENTS: NOT APPLICABLE.
* Regulatory Information *
SARA Title III Information:BASED ON THE DATA AVAILABLE THIS PRODUCT IS
NOT REGULATED BY SARA TITLE III.
Federal Regulatory Information:THE COMPONENTS OF THIS PRODUCT ARE
LISTED ON THE EPA/TOXIC SUBSTANCE CONTROL ACT (TSCA) INVENTORY OF
CHEMICAL SUBSTANCES. THIS PRODUCT IS COVERED BY EPA'S COMPREHENSIVE
ENVIRONMENTAL RESPONSE, COMPENS ATION AND LIABILITY ACT (CERCLA)
PETROLEUM EXCLUSION. THEREFORE, RELEASES TO AIR, LAND, OR WATER ARE
NOT REPORTABLE UNDER CERCLA ("SUPERFUND").HOWEVER, UNDER SECTION
OIL. AS SUCH, SPILLS INTO OR LEADING TO SURFACE WATERS THAT CAUSE
A SHEEN MUST BE REPORTED TO THE NATIONAL RESPONSE CENTER,
State Regulatory Information:THE FOLLOWING CHEMICALS ARE SPECIFICALLY
LISTED BY INDIVIDUAL STATES; OTHER PRODUCT SPECIFIC HEALTH AND
SAFETY DATA IN OTHER SECTIONS OF THE MSDS MAY ALSO BY APPLICABLE
FOR STATE REQUIREMENTS. FOR DE TAILS ON YOUR REGULATORY
REQUIREMENTS YOU SHOULD CONTACT THE APPROPRIATE STATE AGENCY.
MASSACHUSETTS SUBST. LIST: SOLVENT REFINED, HYDROTREATED LIGHT
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE EITHER A FULL-FACE, ATMOSPHERE-SUPPLYING
RESPIRATOR OR AN AIR-PURIFYING RESPIRATOR FOR ORGANIC VAPORS.
Ventilation:NORMAL MECHANICAL VENTILATION.
Other Protective Equipment:CLOTHING AS REQUIRED TO MINIMIZE CONTACT.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING THIS
MATERIAL.
Supplemental Safety and Health
NONE
* Product Identification *
Product ID:METYL ETHYL KETONE
* Composition/Information on Ingredients *
Ingred Name:METHYL ETHYL KETONE (2-BUTA) (MEK) (SARA III)
Other REC Limits: SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MODERATELY IRRITATING. SKIN:
MODERATELY IRRITATIONG. PROLONGED OR REPEATED LIQUID CONTACT CAN
RESULT IN DEFATTING AND DRYING OF THE SKIN WHICH MAY RESULT IN
DERMATITIS. INHALATION: IRRITATION TO NOSE, THROAT AND
RESPIRATORY TRACT.INGESTION: MODERATELY TOXIC AND MAY PRODUCT CNS
DEPRESSION.
Effects of Overexposure:EARLY TO MODERATE CNS DEPRESSION MAY BE
EVIDENCED BY GIDDINESS, HEADACHE, DIZZINESS AND NAUSEA. IN EXTREME
CASES, UNCONSCIOUSNESS AND DEATH MAY OCCUR.
Medical Cond Aggravated by Exposure:PREEXISTING EYE, SKIN, AND
RESPIRATORY DISORDERS.
* First Aid Measures *
MIN. WHILE HOLDING EYELIDS APART. SKIN: FLUSH SKIN WITH WATER
WHILE REMOVING CONTAMINATED CLOTHING AND SHOES. ASSIST WITH
BREATHING, IF NE CESSARY. INGESTION: DO NOT GIVE LIQUIDSIF VICTIM
IS UNCONSCIOUS OR VERY DROWSY, OTHERWISE GIVE 2 GLASSES OF WATER
AND INDUCE VOMITING BY GIVING SYRUP OF IPECAC OR BY TOUCHING BACK
OF THROAT.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1.8
Extinguishing Media:USE WATER FOG. "ALCOHOL" FOAM, DRY CHEMICAL.
Fire Fighting Procedures:FLAMMBLE, DO NOT ENTER CONFINED FIRE SPACE
WITHOUT FULL BUNKER GEAR, INCLUDING A POSITIVE PRESSURE
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:COOL FIRE EXPOSED CONTAINERS WITH WATER
SPRAY.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE SOURCES OF IGNITION. WEAR
APPROPRIATE PROTECTIVE EQUIPMENT. SHUT OFF SOURCE OF LEAK IF SAFE
TO DO SO. REMOVE WITH VACUUM TRUCK OR PUMP TO STORAGE/SALVAGE
VESSELS. SOAK UP RESIDUE WITH AN ABS ORBENT SUCH AS CLAY, SAND, OR
OTHER MATERIAL.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY AREA.
Other Precautions:GROUND FIXED EQUIPMENT. BOND AND GROUND TRANSFER
CONTAINERS AND EQUIPMENT.
* Physical/Chemical Properties *
HCC:F2
Vapor Density:2.5
Solubility in Water:APPRECIABLE
Appearance and Odor:COLORLESS, MOBILE LIQUID. PUNGENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, FLAMES AND SPARKS.
Hazardous Decomposition Products:CARBON MONOXIDE AND UNIDENTIFIED
ORGANIC COMPOUNDS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, OR
FEDERAL REGULATION.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:MECHANICAL:GOOD GENERAL VENTILATION; LOCAL:NOT REQUIRED.
Other Protective Equipment:USUAL LABORATORY PROTECTIVE EQUIPMENT
Work Hygienic Practices:N/K
Supplemental Safety and Health
PH:RT OF ENTRY:FP N.EYE PROT:WORK W/BULK QUAN OF DRY UNRECONST REAGENT.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:P-NITROPHENYL-PHOSPHATE, DITRIS SALT, PERCENT IS BEFORE
RECONSTITUTION
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS AND SYMPTOMS OF OVEREXPOSURE
SECTION .
Explanation of Carcinogenicity:N/A
Effects of Overexposure:MAY CAUSE SKIN, EYE & RESPIRATORY IRRITATION.
Medical Cond Aggravated by Exposure:N/K
* First Aid Measures *
CONSULT PHYS IF IRRI PERSISTS.INHAL:RMV FRM EXPOSURE.SUPPORT
BREATHING(GIVE O*2/ART RESP). INGESTION:CALL MD IMMEDIATELY . SK
PERSISTS.
* Fire Fighting Measures *
Extinguishing Media:USE ALCOHOL FOAM; DRY CHEMICAL OR CARBON DIOXIDE
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR PROTECTIVE EQUIPMENT
AND SELF-CONTAINED BREATHING APPARATUS.
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP DRY. THEN FLUSH AFFECTED AREA WITH
WATER.
Neutralizing Agent:N/K
*Handling and Storage *
Handling and Storage Precautions:STORE AT TEMPERATURE LISTED ON THE
Other Precautions:WASH EQUIPMENT WITH WATER.
* Physical/Chemical Properties *
pH:N/K-FP
Solubility in Water:YES
Appearance and Odor:WHITE TO SLIGHTLY YELLOW POWDER
Corrosion Rate:
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:FOLLOW FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT NORMALLY REQUIRED. USE NIOSH APPROVED
PARTICULATE RESPIRATOR IF CONDITIONS WARRANT.
Ventilation:IF PRODUCT IS ALLOWED TO BECOME AIRBORNE AS DUST, AN
EXHAUST FAN WITH AN EXPLOSION-PROOF MOTOR IS RECOMMENDED.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFFECTS OF OVEREXPOSURE: FLAME. POSSIBLE CANCER HAZARD. CONTAINS
MATERIAL WHICH MAY CAUSE CANCER.
* Product Identification *
CAGE:TECIN
CAGE:TECIN
* Composition/Information on Ingredients *
Ingred Name:CALCIUM CARBONATE
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
OSHA PEL:N/K
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:SILICATE, PORTLAND CEMENT
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
Fraction by Wt: 1-5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: PORTLAND CEMENT CAN CAUSE
EYE IRRIT BY ABSORBING WATER FROM EYES. SKIN: PORTLAND CEMENT CAN
CAUSE IRRITATION BY ABSORBING WATER FROM SKIN. INHALATION: DUSTS
MAY IRRITATE RESPIRATORY TRACT IN SENSITIVE INDIVIDUALS.
INGESTION: NOT AN ANTICIPATED ROUTE OF EXPOSURE. SMALL AMOUNTS ARE
NOT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA-CRYSTALLINE: IARC MONOGRAPHS VOL
BE CARCIN.
Effects of Overexposure:HLTH HAZS: ANTIC TO BE HARMFUL. CHRONIC: WHEN
PROD IS IN FINAL FORM & IS ABRADED/DISTURBED, DUSTING MAY OCCUR &
CRYSTALLINE SILICA MAY BE RELS INTO AIR. LONG-TERM OVEREXP TO
CRYSTALLINE SILICA MAY CAU SE PERM LUNG DMG & REDUCED PULM FUNC.
DUST CLOUDS IN AIR CAN BE IGNITED BY ELECTRIC SPARKS, HOT SURFS &
OPEN (SUPDAT)
Medical Cond Aggravated by Exposure:INHALATION OF DUST MAY AGGRAVATE
LUNG CONDITIONS SUCH AS ASTHMA, EMPHYSEMA OR CHRONIC BRONCHITIS.
* First Aid Measures *
PERSON CAN SWALLOW, GIVE ONE GLASS OF WATER OR MILK. DO NOT INDUCE
VOMIT. GET IMMEDIATE MEDICAL ATTENTION. NEVER GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS PERSON. INHALATION: REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE OXYGEN/ARTIFICIAL RESPIRATION) . SKIN:
FLUSH WITH COPIOUS AMOUNTS OF WATER. CALL MD .
* Fire Fighting Measures *
Extinguishing Media:USE WATER SPRAY, FOAM, DRY CHEMICAL OR CARBON
DIOXIDE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:DUST CLOUDS IN AIR CAN BE IGNITED BY
ELECTRIC SPARKS, HOT SURFACES AND OPEN FLAME.
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP OR VACUUM IMMEDIATELY; AVOID CREATING
DUSTY CONDITIONS. MATERIAL CAN ABSORB WATER AND BECOME SLIPPERY.
SHOVEL UP WET MATERIAL AND FLUSH AREA WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID BREATHING DUST.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION CAN YIELD CARBON
MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:TO BEST OF OUR KNOWLEDGE, PROD DOES NOT MEET
DISPOSE OF IN AN APPROVED LANDFILL. CONSULT STATE, LOCAL, FEDERAL
OR PROVINCIAL AUTHORITI ES FOR MORE RESTRICTIVE REQUIREMENTS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NOT NEEDED.
Ventilation:MECHANICAL (GENERAL) SUFFICIENT.
Other Protective Equipment:USE PROTECTIVE CREAM WHERE EXCESSIVE SKIN
CONTACT IS LIKELY.
Work Hygienic Practices:USE IN ACCORDANCE W/MANUFACTURER'S
INSTRUCTIONS.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Preparer's Name:BEN APONAVICIUS
* Composition/Information on Ingredients *
Ingred Name:ETHANOL, 2-AMINO-; (ETHANOLAMINE)
Fraction by Wt: <5%
OSHA PEL:3 PPM; 6 STEL
ACGIH TLV:3 PPM; 6 STEL
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
Fraction by Wt: <1%
OSHA PEL:2 MG/M3, C
ACGIH TLV:2 MG/M3, C
Ingred Name:GLYCOLS, POLYETHYLENE, MONO(P-(1,1,3,3-TETRAMETHYL
BUTYL)PHENYL) ETHER; (OXTOXYNOL)
Fraction by Wt: <5%
Ingred Name:WATER
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT WAS TESTED TO BE AN EYE
IRRITANT, BUT NOT A PRIMARY SKIN IRRITANT IN ACCORDANCE WITH THE
PROCEDURES OF THE FEDERAL HAZARD SUBSTANCES ACT.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:UNKNOWN.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
OXYGEN/ARTIFICIAL RESPIRATION). CALL MD . EYES/SKIN:FLUSH W/LARGE
OF WATER, DILUTED VINEGAR (1-4) OR LEMON JUICE MAY BE GIVEN.
CONSULT MD OR POISON CONTROL CENTER.
* Fire Fighting Measures *
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE CONDITIONS
. THIS FLUID WILL NOT BURN OR SUPPORT COMBUSTION.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. HIGH TEMPS WILL EVAP WATER & REMAINING RESIDUE WILL BURN. WATER
IS AN ADEQUATE EXTINGUISHING MEDIUM.
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:IS NOT A REGULATED PRODUCT. SPILLS SHOULD BE
CONTAINED, NEUTRALIZED W/A SUITABLE ACID & PLACED IN CONTAINERS FOR
DISPOSAL.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:EXTREME HEAT OR COLD MAY CAUSE
STRATIFICATION WHICH DISAPPEARS AT ROOM TEMPERATURE.
Other Precautions:NONE.
* Physical/Chemical Properties *
HCC:N1
Vapor Pres:LIKE WATER
Vapor Density:LIKE WATER
Evaporation Rate & Reference:LIKE WATER
Solubility in Water:MISCIBLE
Appearance and Odor:WHITE TURBID LIQUID; MILD SOAP ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE, BURY OR RUN INTO SEWER IN ACCORDANCE
W/ALL LEGAL FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:PROVIDE WORKERS W/NIOSH/MSHA APPRVD DUST RESP
WHERE DUST LEVS MAY EXCEED PEL. NIOSH/MSHA APPRVD EQUIP ARE REC
WHEN AIRBORNE FIBER EXPOS LIMS ARE EXCEEDED. NIOSH/MSHA APPRVD
BRTHG EQUIP MAY BE REQ FORNON-ROUTINE & EMER USE. (SEE ING 6)
Ventilation:PROVIDE ADEQUATE GENERAL AND LOCAL EXHAUST VENTILATION TO
MEET PEL REQUIREMENTS.
Other Protective Equipment:PROTECTIVE CLOTHING AND VACUUM CLEAN PRIOR
TO REMOVING CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP: AVERAGED OVER AN 8-HR WORK SHIFT. WHEN THIS PROD IS
REMOVED AFTER ITS USEFUL LIFE(TEAR OUT), DUST GENERATION IS LIKELY.
THE USER SHOULD BE WARNED OF THE CURRENT PEL & PREC SHOULD BE T
AKEN TO AVOID INHAL OF DUST. (ACUTE) IRRIT OF SKIN & UPPER RESP
* Product Identification *
Product ID:CER-WOOL HOT STOP
* Composition/Information on Ingredients *
PROD IS SUSPECTED TO BE AN ANIMAL CARCIN.
Ingred Name:CERAMIC WOOL (CER-WOOL)
Ingred Name:SILICA, AMORPHOUS FUMED (COLLOIDAL SILICA)
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE
OSHA PEL:SEE TABLE Z3
Ingred Name:OTHER PREC: USE/EXPOS. NIOSH/MSHA APPRVD RESP FOR DUST LEVS
Ingred Name:ING 4: USE OF DUST CONTROL EQUIP/WATER SPRAY. WEAR PROT
CLTHG & VACUUM CLEAN PRIOR TO REMOVING CLOTHING.
Ingred Name:RESP PROT: VENT SHOULD BE USED TO CONTROL/REDUCE AIRBORNE
CONC. THE FOLLOWING ACCEP NIOSH/MSHA APPRVD RESP (SEE ING 7)
Ingred Name:ING 6: ARE REC FOR GIVEN AIRBORNE CERAMIC FIBER CONC:
FACEPIECE SUPPLIED-AIR APPRVD AIR SOURCE REQ. (SEE ING 9)
Ingred Name:ING 8:PENDING RESULTS OF LONG-TERM HLTH EFTS STUDIES,
Ingred Name:ING 9: ATTAINABLE IS ADVISED.
Ingred Name:SUPP DATA: TERM EXCESSIVE INHAL OF CRYSTALLINE SILICA DUST.
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:CER-WOOL HOT STOP IS MFR FROM COMBUST
OF CERAMIC FIBER, OF MINERAL FAMILY, SPECIALLY TREATED W/SUSPENSION
OF COLLOIDAL SILICA. THE ACGIH, TLV FOR MINERAL WOOL FIBER, AS DUST
HOWEVER, CRYSTALLINE SILICA (CRISTOBALITE) WILL FORM AFTER (SEE
EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE: GROUP 2A (IARC).
PRESENT A HLTH HAZ IF INHALED OVER LONG PERIOD OF TIME.
CRISTOBALITE IS LISTED IN IARC GR OUP 2A AS A PROBABLE HUMAN
CARCIN. THE CURRENT OSHA PEL IS 5 MG/M3 DIVIDED BY PERCENT FREE
SILICA + TWO, (SEE SUPP DATA)
Medical Cond Aggravated by Exposure:PRE-EXISTING UPPER RESPIRATORY AND
LUNG DISEASES SUCH AS, BUT NOT LIMITED TO, BRONCHITIS, EMPHYSEMA
AND ASTHMA.
* First Aid Measures *
First Aid:SKIN: WASH OFF THOROUGHLY USING A MILD SOAP AND WATER.
INGEST: CALL MD IMMEDIATELY . INHAL: REMOVE TO FRESH AIR. SUPPORT
BREATHING (GIVE O*2/ARTF RESP) .
* Fire Fighting Measures *
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE TO THE
SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THIS PRODUCT IS A NON-COMBUSTIBLE
REFRACTORY.
* Accidental Release Measures *
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:BECAUSE OF POSS PRESENCE OF
CRYSTALLINE SILICA IN FIRED REFRACTORY LININGS, PARTICULAR CARE
SHOULD BE EXERCISED DURING TEAR-OUT TO MIN GEN OF DUST.
Other Precautions:ADHERENCE TO PROPER METHODS OF DUST SUPPRESSION &
CONTROL IS IMPERATIVE. FOLLOW THESE RECOMMENDED PRECAUTIONS DURING
REMOVAL: EMPLOYEES SHOULD BE APPRISED OF HAZARDS & PROPER
CONDITIONS & PRECAUTIONS FOR SAFE (SEE ING 4)
* Physical/Chemical Properties *
HCC:N1
Appearance and Odor:WHITE TO OFF-WHITE FIBER, NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:SOLID WASTE REGULATIONS APPLY. CONSULT LOCAL,
STATE AND FEDERAL REGULATORY AGENCIES TO DETERMINE BEST DISPOSAL
ALTERNATIVES.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE SELF-CONTAINED BREATHING APPARATUS IF
PEL/TLV EXCEEDED AS IN A LARGE SPILL OR CONFINED AREA.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:USE GOOD PERSONAL HYGENE. LAUNDER CONTAMINATED
CLOTHING BEFORE REUSE.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS. NOTE TO PHYSICIAN: ASPIRATION OF THIS
PRODUCT DURING INDUCED EMESIS CAN RESULT IN LUNG INJURY. IF E
VACUATION OF STOMACH CONTENTS IS CONSIDERED NECESSARY, USE METHOD
LEAST LIKELY TO CAUSE ASPIRATION.
* Product Identification *
Product ID:BURNER OIL #2
CAGE:COOL1
CAGE:STARE
* Composition/Information on Ingredients *
Ingred Name:DIESEL FUEL, ALIPHATIC-NITRO FRACTION: NO CAS NO.
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION- NARCOSIS OR
DROWSINESS. EYES- IRRITATION. SKIN- SEVERE IRRITATION. BURNS AND
BLISTERING. INGESTION- IRRITATION, BURNS, BLITERING OF MOUTH,
ESOPHAGUS AND STOMACH. CHRONIC: MANUFACTUR ER STATES POSSIBLE
CANCER OR KIDNEY DAMAGE.
Explanation of Carcinogenicity:MANUFACTURER STATES POSSIBLE CARCINOGEN
FROM "MIDDLE DISTILLATES".
Effects of Overexposure:INHALATION: DIZZINESS, DROWSINESS. EYES:
BURNING SENSATION, REDNESS. SKIN: BURNS, RASH, BLISTERS. INGESTION:
BURNING OF MOUTH AND ESOPHAGUS. NAUSEA, VOMITING, STOMACH PAIN.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS MAY BE
AGGAVATED BY EXPOSURE.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
MINUTES. SEE DOCTOR. SKIN: WASH WITH SOAP AND WATER. INGESTION: DO
NOT INDUCE VO MITING! SEE DOCTOR. SEE DOCTOR IF ANY SYMPTOMS
PERSIST.
* Fire Fighting Measures *
Flash Point Method:PMCC
Upper Limits:4.1 %
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, FOAM, OR CARBON DIOXIDE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE GEAR. USE WATER FOG TO COOL FIRE EXPOSED CONTAINERS
AND TO DIPERSE VAPORS.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:CONTAIN SPILL. ABSORB ON SUITABLE MATERIAL,
SCOOP UP AND PLACE IN CONTAINER FOR DISPOSAL. VENTILATE AREA. AVOID
BREATHING VAPORS. AVOID ALL PERSONAL CONTACT. USE SELF-CONTAINED
BREATHING APPARATUS IN CONFINED AREA.
Neutralizing Agent:NONE
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM HEAT AND IGNITION
Other Precautions:USE ONLY AS A FUEL.
* Physical/Chemical Properties *
HCC:V4
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, BRIGHT LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:HEAT, FLAME AND OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:OXIDES OF CARBON
* Disposal Considerations *
Waste Disposal Methods:IF DISCARDED IN ORIGINAL FORM, DISPOSE OF AS AN
ENVIRONMENTAL MANAGER AND DISPOSE OF IN ACCORDANCE WITH LOCAL,
STATE AND FEDERAL REGULATIO NS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF THE WORK STATION IS NOT PROPERLY VENTILATED
TO EXHAUST ALL FUMES, VAPORS AND DUSTS BELOW THE RECOMMENDED
EXPOSURE LIMITS, USE A NIOSH APPROVED RESPIRATOR.
Ventilation:USE ENOUGH GEN VENT & LOC EXHST AT WORK SITE TO KEEP ALL
FUMES & DUST FROM WORKER'S BREATHING ZONE & GEN AREA.
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
WEAR HAND, HEAD & BODY PROT TO PVNT INJURY FROM RADIA, SPKS & (ING
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP: CAN RSLT FROM OVEREXP TO THESE FUMES. SHORT TERM
OVEREXP MAY RSLT IN DIZZ, NAUS/DRYNESS/IRRIT OF NOSE, THROAT/EYES.
EXCESS OVEREXP MAY CAUSE BRONCH ASTHMA, LUNG FIBROSIS, PNEUMOCONIOS
IS/SIDEROSIS (IRON DEPOSITS IN LUNG). METAL FUME FEVER: CAN BE
CAUSED BY INHAL OF CERTAIN METALLIC CMPDS DURING (ING 9)
* Product Identification *
Product ID:BEAUTYWELD, ARC WELDING ELECTRODE
* Composition/Information on Ingredients *
Ingred Name:POTASSIUM HYDROXIDE (CERCLA)
OSHA PEL:C 2 MG/M3
ACGIH TLV:C 2 MG/M3
Ingred Name:POTASSIUM SILICATE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CLAY (KAOLIN); (KAOLIN)
ACGIH TLV:2 MG/M3 TDUST
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
Ingred Name:FELDSPAR
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:IRON
Fraction by Wt: 1-5%
OSHA PEL:C 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST
Ingred Name:CELLULOSE
Ingred Name:SUP DAT: WELDING, HEATING, BRAZING, SOLDERING/CUTTING
Ingred Name:ING 9: INCL CHILLS, FEVER, HEAD & MUSC ACHE, TIGHTNESS OF
EARLY DETECTION OF MANGANESE POISONING.
FSHLD, & MAY INCL ARM PROT, APRONS, HATS & DARK PROT CLTHG.
Ingred Name:HAZ DECOMP PROD:CMPDS, METAL OXIDES, CARBON & SILICA.
SPECIFIC INFO REGARDING HAZ DECOMP PRODS CONT NEHC .
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: FUMES ASSOC W/HEATING,
WELDING, BRAZING, SOLDERING/CUTTING METALS CAN BE DANGEROUS TO YOUR
HLTH & OVEREXP CAN CAUSE LUNG DMG &/OTHER ORGAN DMG. EYE/SKIN: ARC
RAYS & ULTRAVIOLET LIGHT CAN INJURE EYES & BURN SKIN. LIQS USED IN
FLUXES & CHEM AIDS MAY CAUSE IRRIT/POSS CHEM BURNS. ELEC SHOCK
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: CAN KILL. INGEST: DANGER! MAY BE
HARMFUL/FATAL IF SWALLOWED. GEN WELDING FUMES: ELEC ARC WELDING,
BRAZING, SOLDERING/THERMAL SPRAYING MAY CREATE ONE/MORE OF THE
FOLLOWING HLTH HAZS ASSOC W/K EY INGS. FUMES, GASES & DUSTS CAN BE
DANGEROUS TO YOUR HLTH. CERTAIN MED STUDIES HAVE SUGGESTED THAT
LUNG DMG (SUP DAT)
Medical Cond Aggravated by Exposure:AGGRAVATION OF PREEXISTING
RESPIRATORY OR ALLERGIC CONDITIONS MAY OCCUR IN SOME WORKERS.
* First Aid Measures *
First Aid:INHALATION: MOVE TO FRESH AIR SOURCE. CONTACT MD & ADVISE MD
OF INGS. SKIN: THOROUGHLY WASH HANDS/AFFECTED AREAS W/SOAP & WATER
TO REMOVE ALL RESIDUE. IF RASH/BURN DEVELOPS, CONSULT MD. EYE:
OBTAIN PROMPT MED ADVISE FOR FLUXES & CHEM AIDS. ADVISE MD OF INGS
INGEST: CALL MD AND/LOC POISON CONTROL CENTER. ADVISE OF
INGREDIENTS.
* Fire Fighting Measures *
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL FOAM TYPE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . TOXIC FUMES MAY BE PRODUCED.
Unusual Fire/Explosion Hazard:SOME FLUXES & CHEMS AIDS MAY GIVE OFF
HYDROGEN CHLORIDE, PHOSGENE & CHLORINE GAS. CANS, UNDER PRESS &
FLAMMS, MAY EXPLODE. FOR MORE INFO CONT NEHC .
* Accidental Release Measures *
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:PLEASE READ & UNDERSTAND PROD LBL FOR
PROPER PROC & USE. TRAIN WORKERS NOT TO TOUCH LIVE ELEC PARTS & TO
INSULATE THEMSELVES FROM WORK & ELEC GROUND.
Other Precautions:TRAIN WELDER TO KEEP HIS/HER FACE AWAY FROM FUME/DUST
"THERMAL SPRAYING" PUBLISHED BY AMERICAN WELDING SOCIETY AND OSHA
* Physical/Chemical Properties *
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:REAS EXPECTED CONSTITUENTS OF FUME MAY
INCL: COMPLEX OXIDES OF METALS IN INGS; FLUX COATINGS MAY PRDCE
* Disposal Considerations *
Waste Disposal Methods:DISP OF WASTE MATL, POWDERS, GRINDING/FILTER
RESIDUES IN ENVIRON SENSITIVE MANNER I/A/W FED, STATE & LOC REGS.
USE APPROP MEASURES TO KEEP AIRBORNE DUST LEVELS CONTAINED I/A/W
EXPOS LEVELS OF INGS SEC TION.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHEN APPLYING BULK MATERIAL WITH SPRAY GUN,
ATOMIZATION CAN OCCUR CREATING AN OIL MIST. IN THIS CASE, USE
NIOSH/MSHA APPROVED CHEMICAL MECHANICAL FILTER RESPIRATOR.
Ventilation:FORCED AIR WHEN SPRAYING IN CONFINED SPACES.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH WITH SOAP AND WATER. REMOVE CONTAMINATED
CLOTHING.
Supplemental Safety and Health
FIRE FIGHT PROC: HEAT & FLAME. AVOID SPREADING BURNING LIQ W/WATER USED
FOR COOLING PURPOSES. MOVE UNDAMAGED CONTRS FROM FIRE AREA IF YOU
CAN DO SO W/OUT RISK. FIRST AID PROC: (GIVE OXYGEN/ARTF RESP) .
INGEST: CALL MD IMMED .
* Product Identification *
Product ID:FLUID FILM, FOOD GRADE
* Composition/Information on Ingredients *
Ingred Name:NON-HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES/SKIN: MINIMALLY
IRRITATING. CHRONIC: NO KNOWN HEALTH HAZARDS.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NO KNOWN CONDITIONS.
* First Aid Measures *
IRRIT/REDNESS DEVELOPS, SEEK MED ATTN. SKIN: DO NOT USE GASOLINES,
THINNERS/SOLVS TO REMOVE PROD FROM SKIN. WIPE MATL FROM SKIN &
REMOVE CONTAM CLTHG. CLEANSE AFFECTED AREA THORO BY WASHINGW/SOAP
& WATER &, IF NEC, WATERLESS SKIN CLEANSER. IF IRRIT/REDNESS
DEVELOPS & PERSISTS, SEEK MED ATTN. INHAL: REMOVE TO FRESH AIR.
SUPPORT BRTHG (SUP DAT)
* Fire Fighting Measures *
Flash Point Method:COC
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, WATER SPRAY, FOAM,
SAND OR EARTH. WATER AND FOAM MAY CAUSE FROTHING.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . WATER SPRAY MAY BE USEFUL IN MINIMIZING
VAPORS AND COOLING CONTAINERS EXPOSED TO (SUP DAT)
Unusual Fire/Explosion Hazard:THIS MATERIAL WILL BURN, BUT WILL NOT
IGNITE READILY.
* Accidental Release Measures *
Spill Release Procedures:TRANSFER BULK OF MATERIAL INTO ANOTHER
CONTAINER. ABSORB REMAINING RESIDUE WITH PROPER ABSORBENTS SUCH AS
SAND, EARTH, VERMICULITE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINERS CLOSED AND IN UPRIGHT
POSITION.
Other Precautions:KEEP OUT OF THE REACH OF CHILDREN.
* Physical/Chemical Properties *
Vapor Pres:NEGLIGIBLE
Evaporation Rate & Reference:NEGLIGIBLE
Appearance and Odor:AMBER, OILY LIQUID, WITH MILD PINEY ODOR
Percent Volatiles by Volume:NEGLIG
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STORE AWAY FROM INTENSE HEAT. STORE AWAY FROM STRONG OXIDIZERS
(CHLORINE, BROMINE, HYDROGEN PEROXIDE, NITRIC ACID).
Stability Condition to Avoid:AVOID SKIN OR EYE CONTACT.
Hazardous Decomposition Products:DENSE SMOKE, CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF SULFUR.
* Disposal Considerations *
Waste Disposal Methods:SWEEP UP AND DISPOSE AS SOLID WASTE IN
ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED DUST RESPIRATORS MAY BE
REQUIRED.
Ventilation:UTILIZE LOCAL EXHAUST TO KEEP DUST BELOW TLV.
Other Protective Equipment:IF APPLICABLE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR TRADE NAME/PART #: PRODUCTS, "C" ABRASIVE WHEELS.
* Product Identification *
Product ID:RUBBER BONDED SILICON CARBIDE ABRASIVE (SUPP DATA)
* Composition/Information on Ingredients *
Ingred Name:CURED RUBBER
Fraction by Wt: >4%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SULFUR
Fraction by Wt: >1%
Ingred Name:SODIUM FLUOALUMINATE; (CRYOLITE)
Fraction by Wt: >1%
OSHA PEL:2.5 MG/M3
ACGIH TLV:2.5 MG/M3
Ingred Name:PYRITE (FES)
Fraction by Wt: >1%K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CALCIUM CARBONATE (LIMESTONE)
Fraction by Wt: >1%
Ingred Name:ISOPRENE; (DPR RUBBER)
Fraction by Wt: >1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:1,3-BUTADIENE, 2-CHLORO-; (NEOPRENE)
Fraction by Wt: >1%
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:STYRENE/BUTADIENE
Fraction by Wt: >1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CARBON BLACK
Fraction by Wt: >1%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:GRINDING WHEELS BREAK DOWN DURING USE
AND RESULTING DUST IS CLASSIFIED BY OSHA AS INERT/NUISANCE DUST AND
WOULD HAVE PULMONARY EFFECTS OF INERT DUST.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR AND CONTACT PHYSICIAN IF
NECESSARY. INGEST: CALL MD IMMED . EYE: IMMED FLUSH WITH POTABLE
FLUSH WI TH COPIOUS AMOUNTS OF WATER. CALL MD .
* Fire Fighting Measures *
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA AND COLLECT MATERIAL IN MOST
CONVENIENT AND SAFE MANNER FOR RECLAMATION OR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A DRY AREA. TAKE MEASURES TO
INSURE AGAINST MECHANICAL DAMAGE.
Other Precautions:STORE IN ACCORDANCE WITH ANSI B7.1. RESPIRATORY
PROTECTION MAY BE REQUIRED IN AN EXTREMELY DUSTY ENVIRONMENT. REFER
INSTRUCTIONS PACKED WITH W HEELS.
* Physical/Chemical Properties *
HCC:N1
Spec Gravity:VARIES
Solubility in Water:NOT SOLUBLE
Appearance and Odor:RED, BROWN/GRAY SOLID. HEAT FROM USE MAY PRODUCE A
TYPICAL RUBBER ODOR.
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:UNKNOWN.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN A SECURED SANITARY LANDFILL AND
I/A/W FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR A PROPERLY FITTED NIOSH/MSHA APPROVED DUST
RESPIRATOR IF CONDITIONS ARE DUSTY.
Ventilation:MECHANICAL(GENERAL) VENTILATION IS USUALLY ADEQUATE TO
MAINTAIN DUST LEVELS BELOW TLV FOR NUISANCE DUST.
Other Protective Equipment:LONG SLEEVED WORK CLOTHING. EYEWASH
FOUNTAIN.
Work Hygienic Practices:WASH THOROUGHLY AFTER USE AND BEFORE EATING,
DRINKING OR SMOKING. VACUUM UP ANY DUST. LAUNDER CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
YOU SHOULD KNOW AND FOLLOW ALL THE SAFETY PROCAUTIONS RELATED TO THE
ADSORBED PRODUCTS.
* Product Identification *
Product ID:MOLECULAR SIEVE TYPE 4ADG
* Composition/Information on Ingredients *
Ingred Name:SODIUM OXIDE
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
OSHA PEL:SEE TABLE Z3
Ingred Name:ALPHA-ALUMINA (ALUMINUM OXIDE) (EPA LISTS ONLY FIBROUS
FORMS) (SARA III)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE, SKIN & RESPIRATORY TRACT
IRRITATION. CHRONIC: THE DRYING ACTION OF THIS MATERIAL CAN CAUSE
IRRITATION OF THE MUCOUS MEMBRANES OF THE NOSE AND THROAT AND
IRRITATION OF THE SKIN. AVOID PROLO NGED BREATHING OF THE DUST OR
CONTACT OF DUST WITH THE SKIN.
Explanation of Carcinogenicity:THIS PRODUCT AND ITS COMPONENTS ARE NOT
LISTED ON THE IARC, NTP OR OSHA CARCINOGENS LISTS.
Effects of Overexposure:MAY CAUSE EYE, SKIN & RESPIRATORY TRACT
IRRITATION.
Medical Cond Aggravated by Exposure:MANUFACTURER KNOWS OF NO MEDICAL
CONDITIONS ABNORMALLY AGGRAVATED BY EXPOSURE.
* First Aid Measures *
First Aid:EYES: IMMEDIATELY WASH FROM EYES WITH LARGE AMOUNTS OF WATER,
OCCASIONALLY LIFTING THE UPPER & LOWER EYE LIDS. IF IRRITATION
OCCURS AND PERSISTS, SEEK MEDICAL ATTENTION. SKIN: WASH WITH SOAP
AND WATER . INGESTION: MATERIAL WILL PASS THROUGHTHE BODY NORMALLY.
INHALATION: REMOVE TO FRESH AIR. IF ANY IRRITATION OR SYMPTOMS
PERSIST, SEE A PHYSICIAN.
* Fire Fighting Measures *
Flash Point:DOES NOT BURN
Lower Limits:NOT APPLICAE
Upper Limits:NOT APPLICAE
Extinguishing Media:UNULSED MATERIAL WILL NOT BURN. USE MEDIA
APPROPRIATE FOR THE SURROUNDING FIRE.
Fire Fighting Procedures:DEPENDS ON THE USE OF THE MATERIAL. USED
MATERIAL MAY CONTAIN PRODUCTS OF A HAZARDOUS NATURE. THE USER OF
THIS PRODUCT MUST IDENTIFY THE HAZARDS.
Unusual Fire/Explosion Hazard:IN THEIR FRESH UNUSED STATE, MOLECULAR
SIEVES ARE NOT FLAMMABLE. WHEN EXPOSED TO WATER, HOWEVER, THEY CAN
GET QUITE HOT. FLOODING WILL REDUCE TEMP. TO SAFE LIM.
* Accidental Release Measures *
Spill Release Procedures:SWEEP THE SPILL AREA. COLLECT AND PLACE THE
SPILLED MATERIAL IN A WASTE DISPOSAL CONTAINER. AVOID RAISING DUST.
Neutralizing Agent:NONE REQUIRED
*Handling and Storage *
Handling and Storage Precautions:AVOID PROLONGED BREATHING OF THE DUST
OR CONTACT OF DUST WITH THE SKIN. WHEN HANDLING, WEAR LONG SLEEVES
PROPERLY FITTED NIOSH-APPROVED DUST RESPIRATOR FOR DUSTY
CONDITIONS. BE AWARE OF THE MATERIAL PRESENT ON THE DESSICANT IF
THE MATERIAL IS USED.
* Physical/Chemical Properties *
HCC:N1
Boiling Pt:B.P. Text:NOT APPLICE
Vapor Pres:NOT APPLIE
Vapor Density:NOT APPLIE
Spec Gravity:1.1
Appearance and Odor:DEPENDING ON PRODUCT MAY APPEAR AS BEAD, MESH, CAKE
OR POWDER; ODORLESS.
Percent Volatiles by Volume:NOT AE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
SUDDEN CONTACT WITH HIGH CONCENTRATIONS OF CHEMICALS HAVING HIGH HEATS
OF ADSORPTION SUCH AS OLEFINS, HCL, ETC.
Stability Condition to Avoid:MOISTURE(WATER) CAN CAUSE RISE IN
TEMPERATURE WHICH MAY RESULT IN BURN.
Hazardous Decomposition Products:NONE. MATERIALS MAY BE RETAINED ON THE
SIEVE WHICH MAY THEN DECOMPOSE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN AN APPROVED LANDFILL ACCORDING TO
LOCAL, STATE AND FEDERAL REGULATIONS. COVER PROMPTLY TO AVOID
BLOWING DUST.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:ALWAYS USE A NIOSH-APPROVED RESPIRATOR WHEN
NECESSARY.
Ventilation:ADEQUATE GENERAL/LOCAL EXHAUST VENTILATION TO KEEP AIRBORNE
CONCENTRATIONS <THE PELS.
Other Protective Equipment:PROTECTIVE CLOTHING TO PREVENT SKIN
EXPOSURE.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ACETIC ACID (GLACIAL)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION & BURNS
W/POSSIBLE IRREVERSIBLE DAMAGE. SKIN: SEVERE IRRITATION,
SENSITIZATION, AN ALLERGIC REACTION, DERMATITIS. INGESTION: SEVERE
& PERMANENT DAMAGE TO DIGESTIVE TRACT. INHA LATION: EFFECTS MAY BE
DELAYED. CAUSES RESPIRATORY TRACT IRRITATION. MAY CAUSE CHRONIC
BRONCHITIS & EROSION OF TEETH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, PAIN, NAUSEA, VOMITING, DIARRHEA,
SHOCK
* First Aid Measures *
VOMITING. IF CONSCIOUS & ALERT, GIVE 2-4 CUPFULS OF MILK/WATER.
NEVER G IVE ANYTHING BY MOUTH IF UNCONSCIOUS. INHALATION: REMOVE TO
FRESH AIR IMMEDIATELY. GIVE CPR/OXYGEN IF NECESSARY. OBTAIN MEDICAL
ATTENTION IN ALL CASES. TREAT SYMPTOMATICALLY & SUPPORTIVELY.
* Fire Fighting Measures *
Lower Limits:5.4
Extinguishing Media:SMALL FIRES: DRY CHEMICAL, CO2, WATER
SPRAY/ALCOHOL-RESISTANT FOAM
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING & SELF CONTAINED
BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:REACTS W/MOST METALS TO FORM HIGHLY
FLAMMABLE HYDROGEN GAS WHICH CAN FORM EXPLOSIVE MIXTURES W/AIR.
* Accidental Release Measures *
Spill Release Procedures:ABSORB W/INERT MATERIAL, DRY SAND/EARTH, THEN
PLACE INTO A CHEMICAL WASTE CONTAINER. USE WATER SPRAY TO DILUTE
LEAK TO A NON-FLAMMABLE MIXTURE. AVOID RUNOFF INTO STORM SEWERS &
DITCHES WHICH LEAD TO W ATERWAYS. REMOVE ALL IGNITION SOURCES.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL/DRY/WELL-VENTILATED
AREA AWAY FROM INCOMPATIBLE SUBSTANCES. STORE IN A SUITABLE
CONTAINER IN A DRY AREA >THE PRODUCT'S FREEZING POINT.
Other Precautions:USE W/ADEQUATE VENTILATION. EMPTY CONTAINERS RETAIN
PRODUCT RESIDUE & CAN BE DANGEROUS. DON'T
PRESSURIZE/CUT/WELD/BRAZE/SOLDER/DRILL/GRIND/EXPOSE SUCH CONTAINERS
TO HEAT/SPARKS/OPEN FLAMES. DON'T GET ON SKIN/EYES. AVOID
INGESTION/INHALATION
* Physical/Chemical Properties *
Vapor Density:2.1
pH:2.4
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID W/PUNGENT (VINEGAR) ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACETALDEHYDE, 2-AMINOETHANOL, AMMONIUM NITRATE, BROMINE PENTAFLUORIDE,
CHLORINE TRIFLUORIDE, CHLOROSULFONIC ACID (SUPP)
Stability Condition to Avoid:FREEZING, EXCESSIVE HEAT, SPARKS, FLAMES &
OTHER IGNITION SOURCES
Hazardous Decomposition Products:CO, CO2, HYDROGEN GAS
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:THE SPECIFIC RESPIRATOR SELECTED MUST BE BASED
ON THE CONCENTRATION LEVELS FOUND IN THE WORK PLACE, MUST NOT
EXCEED THE WORKING LIMITS OF THE RESPIRATOR AND JOINTLY APPROVED BY
NIOSH AND MSHA.
Ventilation:PROVIDE LOCAL EXHAUST OR PROCESS ENCLOSURE VENTILATION TO
MEET PUBLISHED EXPOSURE LIMITS.
Other Protective Equipment:EMPLOYEE MUST WEAR APPROPIATE PROTECTIVE
(IMPERVIOUS) CLOTHING & EQUIPMENT. EYE WASH AND SAFETY SHOWER IN
WORK PLACE.
Work Hygienic Practices:CLOTHING SHOULD BE WASHED AFTER EACH USE.
Supplemental Safety and Health
* Product Identification *
Product ID:FERROUS SULFATE HEPTAHYDRATE
* Composition/Information on Ingredients *
Ingred Name:FERROUS SULFATE (SARA III)
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG FE/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALE-MAY CAUSE IRRITATION OF
THE RESPIRATORY TRACT. SKIN-MAY CAUSE IRRITATION. EYE-MAY CAUSE
SEVERE IRRITATION & CORROSIVE ACTION DUE TO THE ACIDITY OF THE
SOLUTION. INGESTION-MAY CAUSE SEVER E POISONING. CHRONIC: SKIN-MAY
CAUSE DERMATITIS. EYE-MAY CAUSE CONJUNCTIVITIS.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:INGEST-HEARTBURN, METALLIC TASTE IN THE MOUTH,
NAUSEA, UPPER GASTRIC DISCOMFORT & CONSTIPATION OR DIARRHEA. SEVERE
POISONING MAY PRODUCE SEVERE HEMORRHAGIC GASTRITIS WITH ABDOMINAL
APIN, RETCHING, VIO LENT DIARRHEA & VOMITING MAY OCCUR. THEVOMITUS
MAY BE BLOODY. DEHYDRATION MAY BECOME INTENSE. DEATH MAY OCCUR.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHALE-REMOVE TO FRESH AIR IMMEDIATELY. IF BREATHING HAS
STOPPED, PERFORM CPR. KEEP WARM & AT REST. SKIN-REMOVE CONTAMINATED
CLOTHES. WASH EFFECTED AREA WITH SOAP OR MILD DETERGENT & LARGE
AMOUNTS OFWATER. EYE-WASH EYES IMMEDIATELY WITH LARGE AMOUNTS OF
WATER. IN CASE OF BURNS, APPLY STERILE BANDAGES LOOSELY.
INGESTION-IF NOT IN SHOCK, INDUCE EMESIS WITH SYRUP OF IPECAC IF
VOMITING HAS'NT OCCURED
* Fire Fighting Measures *
Flash Point:NON-COMBUSTIBLE
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, HALON, WATER SPRAY OR
STANDARD FOAM. FOR LARGE FIRES USE WATER SPRAY, FOG OR STANDARD
FOAM
Fire Fighting Procedures:MOVE CONTAINER FROM FIRE ARE IF POSSIBLE. DO
NOT SCATTER SPILLED MATERIAL WITH HIGH PRESSURE STREAMS. DIKE FIRE
CONTROL WATER FOR LATER DISPOSAL.
Unusual Fire/Explosion Hazard:NEGLIGIBLE FIRE HAZARD WHEN EXPOSED TO
HEAT OR FLAME. AVOID BREATHING HAZARDOUS VAPORS, KEEP UPWIND.
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP AND PLACE IN SUITABLE CLEAN, DRY
CONTAINERS FOR RECLAMATION OR LATER DISPOSAL. DO NOT FLUSH WITH
WATER. KEEP UNNECESSARY PEOPLE AWAY.
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM INCOMPATIBLE
SUBSTANCES.
Other Precautions:PREVENT DISPERSION OF DUST IN AIR. WATER SPILL: ALLOW
SPILLED MATERIAL TO AERATE. NEUTRALIZE WITH AGRICULTURAL LIME,
SLAKED LIME, CRUSHED LIMESTONE OR SODIUM BICARBONATE.
* Physical/Chemical Properties *
HCC:C3
Melt/Freeze Pt:M.P/F.P Text:DECOMPOSES
pH:3.7
Appearance and Odor:ODORLESS, HYGROSCOPIC, BLUE-GREEN, MONOCLINIC
CRYSTALS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ALKALINES, ARSENIC TRIOXIDE + SODIUM NITRATE, METHYL ISOCYANOACETATE
AND OXIDIZERS.
Stability Condition to Avoid:STABLE UNDER NORMAL TEMPERATURES AND
PRESSURES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE TOXIC OXIDES OF SULFUR.
* Disposal Considerations *
Waste Disposal Methods:OBSERVE ALL FEDERAL, STATE AND LOCAL REGULATIONS
WHEN STORING AND DISPOSING OF THIS SUBSTANCE. FOR ASSISTANCE,
CONTACT THE DISTRICT DIRECTOR OF THE ENVIRONMENTAL PROTECTION
AGENCY.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR W/DUAL
ORGANIC VAPOR/MIST & PARTICULATES CARTRIDGE IF VAPOR CONCENTRATION
EXCEEDS PEL.
Ventilation:USE ADEQ LOC EXHST TO MAINTAIN SOLVS BELOW EXPOS LIMITS.
NIOSH/MSHA APPRVD RESP PROT REQD WHEN LEVELS EXCEED LIMITS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
VP:AEROSOL PACKAGE, UNDER PRESSURE. EXPLO HAZ:DO NOT USE NEAR
SPARK/FLAME. HAZ DECOMP PROD:ACID GAS.
* Product Identification *
Preparer's Name:ROBERT KELLAM
* Composition/Information on Ingredients *
Ingred Name:ETHANE, 1,1,1-TRICHLORO-; (1,1,1-TRICHLOROETHANE) (METHYL
Ozone Depleting Chemical:1
Ingred Name:PROPANE
ACGIH TLV:ASPHYXIANT
Ingred Name:PROPANE, 2-METHYL; (ISOBUTANE)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DEOBASE (DEODORIZED KEROSENE); (HYDROCARBON OILS)
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION:HEADACHE, LASSITUDE,
CENTRAL NERVOUS SYSTEM DEPRESSION, DIZZINESS & DISORIENTATION.
INGESTION:POOR EQUILIBRIUM, CARDIAC ARRHYTHMIA, EXCITATION.
CONTACT:DERMATITIS, EYE IRRITATION. CHL OROCARBON MATLS HAVE
PRODUCED SENSIT OFMYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS & COULD
HAVE SIMILAR (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:EFT IN HUMANS. ADRENOMIMETICS (E.G.,
EPINEPHRINE) MAY BE CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINING USES
IN HUMANS ACUTELY OR CHRONICALLY EXPOSED TO CHLOROCARBONS .
CHRONIC:NO DATA AVAI LABLE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
MINUTES & CALL MD. SKIN:REMOVE EXCESS W/CLOTH OR PAPER. WASH
THOROUGHLY W/SOAP & WATER. INHAL:REMOVE VICTIM TO FRESH AIR & CALL
MD IMMEDIAT ELY. IF NOT BRTHG GIVE MOUTH TO MOUTH RESPIRATION. IF
BRTHG IS DFCLT, GIVE OXYGEN. INGEST:CALL MD IMMED. INDUCE VOMIT IF
VICTIM IS CONSCIOUS. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON.
* Fire Fighting Measures *
Flash Point Method:COC
Lower Limits:2.1%
Upper Limits:9.5%
Extinguishing Media:DRY CHEMICAL, WATERFOG, CO*2, FOAM, SAND OR EARTH.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD PRESSURE DEMAND SCBA &
FULL PROT EQUIP . CLOSED CONTAINER EXPOSED TO FIRE MAY BE COOLED
W/WATER. DO NOT USE WATER EXCEPT AS FOG.
Unusual Fire/Explosion Hazard:THERMAL DECOMP PRODS MAY INCL HCL &
PROPANE-ISOBUTANE PROPELLANT. SPRAY IS FLAMM. (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:AVOID ALL IGNIT SOURCES SUCH AS FLAMES & SPKS.
INSURE GOOD VENT. IF VOL IS SIGNIFICANT, TRANSFER INTO CNTNRS FOR
DISP. SEAL CNTNRS TIGHTLY. ABSORB ON INERT ING SUCH AS EARTH,
SAND/VERMICULITE. SWEEP U P & DISPOSE OF ACCORDING TO FED, STATE &
LOC REGS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:CONTAINS PROPANE-ISOBUTANE PROPELLANT.
DO NOT SPRAY ON HOT SURFS/NEAR SPKS/FLAMES. DO NOT HANDLE/STORE AT
Other Precautions:NO SMOKING IN AREA OF USE. DO NOT USE IN GENERAL
VICINITY OF ARC WELDING, OPEN FLAMES OR HOT SURFACES. HEAT &/OR UV
RADIATION MAY CAUSE THE FORMATION OF HCL &/OR PHOSGENE .
* Physical/Chemical Properties *
Vapor Pres:SUPP DATA
Vapor Density:HVR/AIR
Appearance and Odor:AEROSOL, VISCOUS BLACK LIQUID; CHLORINATED SOLVENT
ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS SUCH AS HYDROGEN PEROXIDE, BROMINE & CHROMIC ACID.
Stability Condition to Avoid:PRODUCT IS STABLE UNDER NORMAL CONDITIONS.
Hazardous Decomposition Products:HCL, PHOSGENE . CARBON MONOXIDE,
CARBON DIOXIDE & PHOSPHOROUS FROM BURNING. OXIDES OF SULFUR,
HYDROCHLORIC(SUPDAT)
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF I/A/W ALL APPLICABLE FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SHOULD BE NEEDED.
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE. KEY1:C4.
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:WATER
Other REC Limits:NONE RECOMMENDED
Ingred Name:(NITRILOTRIS(METHYLENE)TRIPHOSPHONIC ACID, K SALT
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. MAY CAUSE TRANSIENT EYE IRRITATION. LOW
SKIN CONTACT HAZARD FOR RECOMMENDED HANDLING. EXPECTED TO BE A LOW
INGESTION HAZARD.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMMEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
* Fire Fighting Measures *
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL
FOAM
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY PRODUCE
HAZARDOUS DECOMPOSTION PRODUCTS.
* Accidental Release Measures *
Spill Release Procedures:FLUSH TO SEWER IF ALLOWABLE WITH LARGE AMOUNTS
OF WATER. OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT
MATERIAL, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN
SURFACE TO REMOVE RESIDUA L CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION. WASH
THOROUGHLY AFTER HANDLING. KEEP FROM CONTACT WITH OXIDIZING
MATERIALS. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:KEEP AWAY FROM INCOMPATIBLE MATERIALS.
* Physical/Chemical Properties *
HCC:C2
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Decomp Temp:Decomp Text:NOT GIVEN
Vapor Density:0.6
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT YELLOW LIQUID, AMMONIA ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
OXIDES OF NITROGEN, OXIDES OF PHOSPHORUS.
* Disposal Considerations *
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. MAY REQUIRE NEUTRALIZATION IF PH
FEDERAL, STATE AND L OCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE DUST RESP AS REQD.
Ventilation:LOCAL OR GENERAL AS REQD
Other Protective Equipment:EYE FOUNTAIN, SAFETY SHOWER
Supplemental Safety and Health
* Product Identification *
Product ID:SALICYLIC ACID
* Composition/Information on Ingredients *
* Hazards Identification *
Effects of
Overexposure:EYE:IRRT,BURN.SKN:IRRT.RASH,BURN.INHL;INGEST:BURN,VOMI
T,RAPID BRTH,NAUS,HEAD,DIZZ,DIARR,CONF,CONVULS
* First Aid Measures *
First Aid:INHAL:RMV TO FRESH AIR. IF NOT BRTHNG GIVE CPR; IF BRTHNG
DIFF GIVE OXYGEN. EYE:IMMED FLUSH W/PLENTY OF WATER. SKIN:WASH
W/SOAP&WATER. RMV CONTAM CLTHG&SHOES. INGEST:INDUCE VOMIT. RPT
UNTIL VOMIT IS C LEAR. NOTHG BY MOUTH IF UNCONSC. GET MEDICAL ATTN.
* Fire Fighting Measures *
Extinguishing Media:WATER FOG, FOAM, ALCOHOL FOAM, CO*2, DRY CHEM
* Accidental Release Measures *
Spill Release Procedures:SWEEP OR VACUUM FOR RECLAIM. AVOID CREATING
DUST. AVOID CONTACT EYE,SKN. REMOVE IGNITION SOURCES-DUST IS
COMBUSTIBLE. AVOID INHL DUST.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL,DRY AREA AWAY FROM
SUNLIGHT.KEEP CONTAINERS CLOSED.
Other Precautions:AVOID SKIN,EYE CONTACT.AVOID INHL DUSTS.
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:SLIGHT
Appearance and Odor:WHITE,ODORLESS CRYSTALS;DISCOLORS IN SUNLIGHT
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
BASIC MATL, IRON SALTS, LEAD ACETATE, IODINE
Hazardous Decomposition Products:THERMAL DECOMP YIELDS ACRID SMOKE
* Disposal Considerations *
Waste Disposal Methods:LANDFILL OR INCINERATE IAW ALL LAWS & REGS IN
APPROVED FACILITY.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:AVOID BREATH VAPOS.SELECT ONE OF FOLLOWING NIOSH
APPROVED RESP BASED ON AIRBORNE CONCEN OF CONTAMINANTS & IAW OSHA
RES:HALF-MASK ORGANIC VAPOR RESPIRATOR.
Ventilation:PROVIDE SUFFI VENTI TO MAINTAIN EMISSIONS BEL RECOMMENDED
EXPO LIMITS.EXHAU VENTI NOT ADEQUATE USE APPROPR RESP PROT.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
RESIDUE W/DECONTAMIN SOLN. 2-PART KIT:PART A=PRE;PART B=POL.
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:POLYBUTADIENE
Other REC Limits:NONE RECOMMENDED
(DECARBROMODIPHENYL ETHER)
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIUNDECYL PHTHALATE
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYOXYPROPYLENE GLYCOLS
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: 7-9%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.5 MG (SB)/M3
Ingred Name:CALCIUM-IRON-MAGNESIUM-VANADIUM CONTAINING ZEOLITE
Fraction by Wt: 7-9%
Other REC Limits:NONE RECOMMENDED
Ingred Name:N,N DI(2-HYDROXYPROPYL)-ANILINE
Fraction by Wt: 5-8%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIPROPYLENE GLYCOL
Fraction by Wt: 3-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:CARBON BLACK
Fraction by Wt: 1-2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3.5 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYE:MILD IRRIT.SKIN:ALLERGIC SKIN
RX.MILD SKIN IRRIT.INHAL:PROL/REP OVEREXPO ABOVE RECOMMENDED
GUIDELINES MAY CAUSE ALLERGIC RESP RX,NERVOUS SYSTEM EFFECTS,UPPER
RESP TRACT IRRIT,LUNG DMG.INGEST:NOT L IKELY ROUTE OF EXPO.ILLNESS
MAY RESULT FROM SINGLE INGEST OF MODERATE QUANT OF MATL.IRRIT GI
TISSUES,PAIN,VOMIT,NAU.
Explanation of Carcinogenicity:PER MSDS:ANTIMONY TRIOXIDE:IARC 2B,CA
Effects of
Overexposure:EYE:RED,SWELL,PAIN,TEAR.SKIN:RX:RED,SWELL,BLISTER,ITCH
.IRRIT:RED,SWELL,ITCH.INHAL:ALLERGIC RESP:DIFFI BREATH,WHEEZ,TIGHT
CHEST,RESP FAILURE.NERV SYST:EMOTIONAL CHANGES,LACK OF
COORD,TREMORS,SENSORY LO SS.IRRIT:SORE
NOSE/THROAT,COUGH,SNEEZE.LUNG:COUGH,DIFF BREATH,WHEEZE,TIGHT
CHES,CONGEST,COUGH BLOOD.INGEST:ABD TENDER,BL
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:EYE:IMMED FLUSH W/LG AMTS OF WATER.GET IMMED MED
ATTN.SKIN:FLUSH W/LG AMTS OF WATER.IRRIT PERSISTS GET MED
ATTN.INHAL:REMOVE TO FRESH AIR.NOT BREATH GIVE ART RESP;DIFF BREATH
GET IMMED MED ATTN.INGEST :DO NOT INDUCE VOMIT.DRINK 2 GLASSES
OFWATER.CALL PHYSICIAN.
* Fire Fighting Measures *
Flash Point Method:SCC
Autoignition Temp:Autoignition Temp Text:N/DETR
Lower Limits:N/DETERMINED
Upper Limits:N/DETERMINED
Extinguishing Media:CARBON DIOXIDE,DRY CHEMICAL,FOAM.
Fire Fighting Procedures:WEAR FULL PROT CLOTH INCLUDE
HELMET,SELF-CONTAINED +PRESSURE/PRESSURE DEMAND BREATH
APPARATUS,BUNKER COAT/PANTS,BAND AROUND ARMS/WAIST/LEGS,FCMASK,PROT
(SUPPLE)
Unusual Fire/Explosion Hazard:CARBON MONOXIDE,CARBON DIOXIDE,OXIDES OF
NITROGEN,HYDROGEN CYANIDE,ISOCAYANATES.
* Accidental Release Measures *
Spill Release Procedures:REFER TO MSDS OTHER SECTIONS.CALL
IN APPROV DR,DONT(SUPPL)
DETERGENT
*Handling and Storage *
Handling and Storage Precautions:DO NOT INGEST.AVOID EYE/PROL/REP SKIN
CONTACT.KEEP CNTNR IN WELL-VENTI AREA.KEEP OUT OF REACH OF
CHILDREN.KEEP CNTNR TIGHTLY CLOSED.
Other Precautions:DONT HEAT UNDER CONFINEMENT.
* Physical/Chemical Properties *
HCC:N1
Boiling Pt:B.P. Text:NA
Melt/Freeze Pt:M.P/F.P Text:N/DETERMIND
Decomp Temp:Decomp Text:NP
Vapor Pres:NA
Vapor Density:NA
pH:NA
Viscosity:8P
Evaporation Rate & Reference:NA
Solubility in Water:REACTS
Appearance and Odor:BLACK VISCOUS LIQUID.
Percent Volatiles by Volume:NP
Corrosion Rate:NP
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AMINES,ALCOHOLS,WAER.RX W/WATER,ALCOHOLS & AMINES NOT HAZ IF CNTNR CAN
VENT TO ATMOSPHER TO PREVENT PRESSURE BUILDUP.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
OXIDES OF NITROGEN, HYDROGEN CYANIDE, ISOCYANATES.
* Disposal Considerations *
Waste Disposal Methods:CONTAINS TOXIC CHEMS SUBJ TO REPORTING REQMTS OF
FACIL.DISPO OF COMPLETELY CURED(OR POLYMERIZED)MATL IN SANITARY
LANDFILL.SINCE REGS V ARY CONSULT APPLICABLE REGS/AUTHORITIE BEF
DISPO.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPRVD RESPIRATOR FOR PROTECTION
AGAINST PNEUM PRODUCING DUSTS RECOM WHEN DUST IS PRESENT. IF DUST
DUST FILTER/SINGLE USE DUS T RESP W/VALVE.IF DUST (SUPP DATA)
Ventilation:LOC-CNTRL W/IN RECOM TLV. REFER TO ACGIH PUBLICATION
"INDUSTRIAL VENT" OR SIMILAR PUBLICATIONS FOR DESIGN OF VENT SYS.
Other Protective Equipment:NOT NORMALLY NECESSARY.
Work Hygienic Practices:AVOID CREATING DUST, MAINTAIN GOOD HOUSEKEEPING
PRACTICES, & SUPPLY PROPER RESPIRATORY PROTECTION.
Supplemental Safety and Health
HLTH HAZ: "PROBABLE CARCIN". CRYSTALLINE SILICA HAS NOT BEEN
NIOSH/MSHA APPRVD AIR-PURIFYING (POS PRESS) RESP W/REPLACEABLE
FILTER;(ING 3)
* Product Identification *
CAGE:EAGLE
CAGE:EAGLE
* Composition/Information on Ingredients *
Ingred Name:SILICONE DIOXIDE; (DIATOMACEOUS EARTH, FLUX-CALCINED)
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE; (CRYSTALLINE SILICA AS
CRISTOBALITE)
OSHA PEL:SEE TABLE Z3
CONT FLOW TYPE (POS PRESS), WITH FULL FACEPIECE, HOOD/HELMET.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: UPPER RESP IRRIT-MAY CAUSE
COUGHING/THROAT IRRIT. CHRONIC: INHAL OF DUST IN EXCESS OF TLV
RECOM BY OSHA OVER AN EXTENDED NUMBER OF YRS MAY CAUSE SILICOSIS,
PROGRESSIVE SOMETIMES FATAL LUNG DISE ASE. ALTHOUGH SILICOSIS IS
NONCANCEROUSLUNG DISEASE, CRYSTALLINE SILICA HAS BEEN DETERMINED BY
IARC TO BE (SUPP DATA)
Explanation of Carcinogenicity:CRYSTALLINE SILICA: GROUP 2A
(IARC);GROUP 2 (NTP).
Effects of Overexposure:INHALATION: ACUTE OVEREXP CAN CAUSE DRYNESS OF
NASAL PASSAGES AND CONGESTION OF UPPER RESPIRATORY SYSTEM. SKIN:
MAY CAUSE DRYNESS; NOT ABSORBED BY SKIN. INGESTION: NOT INTENDED
FOR INGESTION-EARTHY TA STE AND TEXTURE. EYES: TEMPORARY IRRITATION
OF INFLAMMATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. SKIN: NONE NECESSARY-IF
DRYNESS OCCURS, USE MOISTURE RENEWING LOTIONS. INGESTION: SHORT
TERM EXPOSURES NOT CONSIDERED HARMFUL-DRINK WATER TO REDUCE BULK
AND DRYING EFF ECTS. EYES: WASH WITH GENEROUS QUANTITIES OF WATER.
CONSULT PHYSICIAN IF IRRITATION PERSISTS.
* Fire Fighting Measures *
Flash Point:NONFLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE CONDITIONS .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONFLAMMABLE.
* Accidental Release Measures *
Spill Release Procedures:VACUUM CLEAN SPILLAGE, WET SWEEP OR WASH AWAY.
AVOID CREATING DUST.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID CREATING DUST, REPAIR OR
PROPERLY DISPOSE OF BROKEN BAGS.
Other Precautions:NOT NORMALLY NECESSARY.
* Physical/Chemical Properties *
HCC:N1
Spec Gravity:2.3
Solubility in Water:<2%
Appearance and Odor:ODORLESS, WHITE POWDER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
HYDROFLUORIC ACID-SILICA MAY REACT VIOLENTLY WITH HYDROFLUORIC ACID.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE KNOWN.
* Disposal Considerations *
Waste Disposal Methods:NON-BIODEGRADABLE, USE SOLID WASTE DISPOSAL
COMMON TO LANDFILL TYPE OPERATIONS OF SIMILAR DISPOSAL OR IN SLURRY
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED ORGANIC CANISTER MASK OR AIR
PACK AS REQUIRED.
Ventilation:LOCAL EXHAUST AND MECHANICAL (GENERAL) DESIRABLE.
Other Protective Equipment:LONG PANTS, LONG SLEEVED SHIRT, IMPERMEABLE
BOOTS AS NECESSARY TO PROTECT AGAINST PROLONGED OR REPEATED
CONTACT.
Work Hygienic Practices:USE GOOD PERSONAL HYGIENE. WASH THORO W/SOAP &
WATER AFTER USING THIS MATL. CONTAMD CLTHG SHOULD BE WASHED
(SUPDAT)
Supplemental Safety and Health
HYGIENE PRACT: BEFORE REUSE AND LEATHER ITEMS SHOULD BE ALLOWED TO AIR
BEFORE BEING WORN AGAIN.
* Product Identification *
Product ID:TOTAL KILL
Preparer's Name:A.F. ARMER
* Composition/Information on Ingredients *
Ingred Name:DISTILLATES (PETROLEUM), LIGHT CATALYTIC CRACKED; (AROMATIC
PETROLEUM OIL)
OSHA PEL:N/K
ACGIH TLV:0.5 MG/M3 (MFR)
Ingred Name:S-TRIAZINE, 2,4-BIS(ISOPROPYLAMINO)-6-METHOXY-; (PROMETON)
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: SLIGHT SKIN AND/OR EYE
IRRITATION. VAPORS MAY CAUSE HEADACHE AND STUPOR. ANESTHESIA.
INGESTION MAY CAUSE IRRITATION OF STOMACH RESULTING IN NAUSEA AND
VOMITING. CHRONIC: NONE KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
OXYGEN/ARTIFICIAL RESPIRATION) . EYES: FLUSH EYES WITH PLENTY OF
WATER. INGEST: DO NOT INDUCE VOMITING. GET MEDICAL ATTENTION IF
INGESTED.
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:0.7%
Upper Limits:5.0%
Extinguishing Media:CARBON DIOXIDE, DRY FOAM, DRY CHEMICALS.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . DO NOT USE WATER EXCEPT AS A FOG.
Unusual Fire/Explosion Hazard:HANDLE AS A COMBUSTIBLE LIQUID.
* Accidental Release Measures *
Spill Release Procedures:AVOID OPEN FLAME OR SPARK SOURCES. PROVIDE
ADEQUATE VENTILATION. ABSORB WITH INERT MATERIAL. WASH DOWN WITH
DETERGENT AND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID OPEN FLAMES AND SPARK SOURCES.
AVOID SPLASH FILLING. PROVIDE ADEQUATE VENTILATION. AVOID EXCESSIVE
HEAT.
Other Precautions:AVOID CONTAMINATION OF FEED AND FOODSTUFFS. KEEP
LIVESTOCK AND OTHER ANIMALS OFF TREATED AREAS.
* Physical/Chemical Properties *
Vapor Density:7.1
Solubility in Water:EMULSIFIABLE
Appearance and Odor:DARK BROWN LIQUID, HYDROCARBON ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, HYDROGEN CHLORIDE,
PHOSGENE.
* Disposal Considerations *
Waste Disposal Methods:SANITARY LANDFILL OR BY OTHER PROCEDURES
APPROVED BY FEDERAL, STATE AND LOCAL AUTHORITIES.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE A NIOSH-APPROVED RESPIRATOR AS REQUIRED TO
PREVENT OVEREXPOSURE. NOT ORDINARILY REQUIRED.
Other Protective Equipment:AS REQUIRED TO MINIMIZE CONTACT.
Work Hygienic Practices:WASH WITH SOAP AND WATER BEFORE EATING,
DRINKING, SMOKING, APPLYING COSMETICS OR USING TOILET FACILITIES.
Supplemental Safety and Health
LAUNDER CONTAMINATED CLOTHING BEFORE REUSE. CONTAMINATED LEATHER
ARTICLES, EVEN SHOES, CANNOT BE DECONTAMINATED & SHOULD BE
DESTROYED TO PREVENT REUSE. MAY CAUSE IRRITATION. IN GENERAL, NO
TREATMENT N ECESSARY UNLESS LARGE AMOUNTS OF PRODUCT ARE INGESTED.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:BISPHENOL A/EPICHLOROHYDRIN BASED EPOXY RESIN
Other REC Limits:NONE SPECIFIED
Ingred Name:PRODUCED BY CONDENSATION OF EPICHLOROHYDRIN & BISPHENOL A.
RESIDUAL LEVELS OF EPICHLOROHYDRIN ARE CONTROLLED TO 1PPM-MAX
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Health Hazards Acute and Chronic:EYE: MODERATELY IRRITATING TO THE
EYES. CONTACT W/PRODUCT AT ELEVATED TEMPERATURES CAN RESULT IN
THERMAL BURNS. SKIN: MODERATELY IRRITATING TO THE SKIN. PRODUCT MAY
CAUSE SKIN SENSITIZATION. CONTACT W /PRODUCT AT ELEVATED
TEMPERATURES CAN RESULT IN THERMAL BURNS. INHALATION: BECAUSE OF
ITS LOW VOLATILITY, THIS PRODUCT
Effects of Overexposure:IS NOT LIKELY TO BE AN INHALATION HAZARD.
INGESTION: BASED ON PRODUCT TESTING, PRODUCT IS CONSIDERED TO HAVE
A LOW ORDER OF ACUTE ORAL TOXICITY. SKIN: SENSITIZATION (ALLERGY)
MAY BE EVIDENCED BY RASHE S, ESPECIALLY HIVES.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN AND EYE DISORDERS
MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT. PRE-EXISTING SKIN OR
LUNG ALLERGIES MAY INCREASE THE CHANCE OF DEVELOPING INCREASED
ALLERGY SYMPTOMS FROM EXPOSURE.
* First Aid Measures *
CONTAM CLOTH/SHOES & WIPE EXCESS FROM SKIN. FLUSH W/ WATER. WASH
W/SOAP/WATER. CAREFULLY REMOVE CLOTH; IF CLOTH IS STUCK TO BURN
AREA, DO NOT PULL OFF/CUT AROUND IT. COVER AREA W/CLEAN MAT'L.
INHALE: REMOVE TO FRESH AIR. GIVE OXYGEN IF BREATHING DIFFICULT.
INGEST: DO NOT INDUCE VOMIT. GET NEEDED MEDICAL AID FOR EACH
CONDITION.
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:N/AV
Upper Limits:N/AV
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEMICAL OR CO2.
Fire Fighting Procedures:WILL NOT BURN UNLESS PREHEATED. DO NOT ENTER
CONFINED FIRE SPACE W/O FULL BUNKER GEAR, INCLUDING POS PRESS NIOSH
APPR'D SCBA. COOL FIRE EXPOSED CNTNRS W/WATER.
* Accidental Release Measures *
Spill Release Procedures:LG SPILL: WEAR RESPIRATOR & APPROP PROTECT
CLOTH. SHUT OFF LEAK SOURCE IF SAFE TO DO. DIKE/CONTAIN. REMOVE
W/VACUUM TRUCKS OR PUMP TO STORAGE/SALVAGE VESSELS. SOAK UP
W/ABSORB. FLUSH AREA W/ WATER. SM SPILL: TAKE UP W/ABSORB MAT'L &
PROPERLY DISPOSE.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, DRY PLACE. KEEP FROM
OPEN FLAME/HIGH TEMPS. CONTAINERS (EVEN EMPTY) CONTAIN RESIDUES.
HANDLE PER HAZARD POTENTIAL OF CURING AGENT USED.
MAY OCCUR. DO NOT BREATH FUMES. AVOID CONTACT W/EYES & PROLONGED OR
REPEATED C ONTACT W/SKIN.
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:VERY LIGHT YELLOW, VERY VISCOUS LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXID AGENTS, STRONG LEWIS/MNRL ACIDS & STRONG MNRL & ORGANIC
BASES/ESPECIALLY PRIMARY/SECONDARY ALIPHATIC AMINES.
Stability Condition to Avoid:REACTS W/SOME CURING AGENTS. RUN-A-WAY
CURE REACTIONS MAY CHAR/DECOMPOSE RESIN SYSTEM, GENERATING TOXIC
FUMES/VAPORS.
Hazardous Decomposition Products:CARBON MONOXIDE, ALDEHYDES, ACIDS &
OTHER ORGANIC SUBSTANCES MAY BE FORMED DURING COMBUST OR ELEVATED
TEMP DEGRADATION.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NOT NORMALLY REQUIRED.
Ventilation:LOCAL EXHAUST:KITCHEN FAN OVER BOILING TANK. MECHANICAL
(GENERAL):NORMAL OFFICE VENTILATION.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . LAB COAT OR APRON IF DESIRED.
Work Hygienic Practices:NORMAL PERSONAL HYGIENE (CLEANLINESS) IS
SATISFACTORY.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Product ID:LIQUID SEALING CONCENTRATE
* Composition/Information on Ingredients *
Ingred Name:NICKEL ACETATE TETRAHYDRATE
OSHA PEL:N/K
ACGIH TLV:1 MG/M3 AS NI
Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: BALANCE
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF EYES AND SKIN FROM
CONTACT. ALLERGIC SENSITIZATION IN SOME INDIVIDUALS TO NICKEL
SOLUTIONS. EYE OR SKIN CONTACT:IRRITATION. INHALATION:UPPER
RESPIRATORY IRRITATION. INGESTION:NAUSEA.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:SKIN DISORDERS MAY BE AGGRAVATED BY
PROLONGED SKIN CONTACT.
* First Aid Measures *
& WATER. INHAL:REMOVE TO FRESH AIR. INGEST:GET MEDICAL ATTENTION &
GIVE WATER.
* Fire Fighting Measures *
Flash Point:NOT FLAMMABLE
Extinguishing Media:WATER.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
* Accidental Release Measures *
Spill Release Procedures:SPILLS SHOULD BE COLLECTED FOR DISPOSAL. SMALL
QUANTITIES MAY BE TREATED IN AEROBIC WASTEWATER TREATMENT SYSTEMS.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL AREA IN ORIGINAL
CONTAINER.
Other Precautions:NONE.
* Physical/Chemical Properties *
Vapor Density:<1
Spec Gravity:1.1 (H*2O=1)
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:INFINITE; AQ SOLN.
Appearance and Odor:GREEN LIQUID; SLIGHT VINEGAR ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:NONE EXPECTED.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . CONTAINS HEAVY METAL. NICKEL IN SOLUTION MAY BE
PRECIPITATED AS THE HYDROXIDE FOR RECLAMATION OR DISPOSAL.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR NIOSH APPROVED RESPIRATOR BY AN INDUSTRIAL
HYGIENIST MAY BE NECESSARY. A FULL FACEPIECE RESPIRATOR ALSO
PROVIDES EYE & FACE PROTECTION.
Ventilation:LOCAL EXHAUST VENTILATION WHEN SPRAYING/CURING AT ELEVATED
TEMP.
Other Protective Equipment:IMPERVIOUS APRON, WORKPANTS, LONG SLEEVE
WORK SHIRT, DISPOSABLE COVERALLS, BARRIER CREAMS, EYEWASH, SAFETY
SHOWER.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
* Product Identification *
DEP
* Composition/Information on Ingredients *
Ingred Name:MODIFIED POLY(AROMATIC GLYCIDYL ETHER)*
Ingred Name:POLY(AROMATIC GLYCIDYL ETHER)
Ingred Name:PHENOLIC RESIN
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE ALLERGIC SKIN
REACTION/PRIMARY IRRITATION W/EPOXY RESINS. OVEREXPOSURE TO VAPOR
DURING HEAT CURING MAY CAUSE IRRITATION/INJURY OF THE RESPIRATORY
TRACT & EYE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
* First Aid Measures *
First Aid:SKIN: WASH W/SOAP & PLENTY OF WATER. OBTAIN MEDICAL ATTENTION
IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:USE WATER, CO2/DRY CHEMICAL.
Fire Fighting Procedures:WEAR SCBA IN POSITIVE PRESSURE MODE.
* Accidental Release Measures *
Spill Release Procedures:WHERE EXPOSURE LEVEL ISN'T KNOWN, WEAR NIOSH
APPROVED POSITIVE PRESSURE SELF CONTAINED RESPIRATOR. WHERE IT IS
KNOWN, WEAR NIOSH APPROVED RESPIRATOR SUITABLE FOR LEVEL OF
EXPOSURE. SWEEP UP & PLACE IN A WASTE DISPOSAL CONTAINER. FLUSH
AREAW/WATER.
*Handling and Storage *
Other Precautions:AVOID PROLONGED/REPEATED CONTACT W/SKIN.
* Physical/Chemical Properties *
Spec Gravity:-1.3
Solubility in Water:NEGLIGIBLE
Appearance and Odor:RED SLIGHTLY TACKY FILM W/NO ODOR.
Percent Volatiles by Volume:<1/WT
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, BASES/AMINES, OXIDIZING AGENTS.
Hazardous Decomposition Products:THERMAL: CO, CO2, SULFUR DIOXIDE,
OXIDES OF NITROGEN, AMMONIA, HYDROGEN CYANIDE & OXIDES OF
PHOSPHORUS.
Conditions to Avoid Polymerization:CONTACT W/ACIDS, OXIDIZING AGENTS,
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE MADE IAW/APPLICABLE
GOVERNMENTAL REGULATIONS.
| 1 | gloves_mandatory |