text
stringlengths 307
13.1k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 4-6 RM VALUME/HR)
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS.
Other Protective Equipment:EYE BATH, WASHING FACILITIES, SAFETY SHOWER
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
ECOLOGICAL INFORMATION: THIS MATERIAL HAS NOT BEEN TESTED FOR
ENVIRONMENTAL EFFECTS. IN A SPILL SITUATION, THESE MATERIALS MAY BE
VISUALLY UNPLEASANT; HOWEVER, IT IS NOT EXPECTED TO CAUSE ADVERSE
ENVI RONMENTAL EFFECTS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:STYRENE ACRYLATE COPOLYMER
Other REC Limits:NONE RECOMMENDED
Ingred Name:IRON OXIDE
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:5 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES. ACUTE- EYES:NO
SPECIFIC HAZARD KNOWN. MAY CAUSE TRANSIENT IRRITATION. SKIN:LOW
HAZARD FOR RECOMMENDED HANDLING. INHALE:EXPECTED TO BE A LOW HAZARD
FOR RECOMMENDED HANDLING. ORAL:EX PECTED TO BE A LOW INGESTION
HAZARD. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:TRANSIENT EYE IRRITATION
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING EYE
PROBLEMS MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.
* First Aid Measures *
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
SKIN:WASH WITH SOAP & WATER. ORAL:DRINK 1-2 GLASSES OF WATER. SEEK
MEDICA L ATTENTION. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON.
* Fire Fighting Measures *
Flash Point:NONE
Lower Limits:NOT RELEVANT
Upper Limits:NOT RELEVANT
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL. WATER
SPRAY MAY BE USED TO KEEP FIRE EXPOSED CONTAINERS COOL.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. HAZARDOUS DECOMPOSITION
PRODUCTS MAY BE FORMED.
Unusual Fire/Explosion Hazard:POWDERED MATERIAL MAY FORM EXPLOSIVE
DUST-AIR MIXTURES.
* Accidental Release Measures *
Spill Release Procedures:CAREFULLY, SWEEP MATERIAL ONTO PAPER AND PLACE
IN A FIBER CARTON. CLEAN SPILL AREA THOROUGHLY TO REMOVE RESIDUAL
CONTAMINATION. DO NOT USE A VACUUM CLEANER TO CLEAN UP SPILL OF
POWDERED TONERS. THE VE RY FINE PARTICLES CAN CAUSE A FIRE OR
EXPLOSION.
Neutralizing Agent:NOT RELEVANT
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED. STORE AWAY FROM
STRONG OXIDIZING AGENTS. MINIMIZE DUST GENERATION AND ACCUMULATION.
Other Precautions:AVOID CONTACT WITH EYES. USE WITH ADEQUATE
VENTILATION. WASH THOROUGHLY AFTER HANDLING. KEEP OUT OF REACH OF
CHILDREN. DO NOT BREATHE DUST.
* Physical/Chemical Properties *
HCC:N1
NRC/State Lic Num:NOT RELEVANT
Spec Gravity:1.4 - 1.6
Viscosity:NOT RELEVANT
Evaporation Rate & Reference:NOT RELEVANT
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER - SLIGHT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:DUST FORMATION
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF IRON
* Disposal Considerations *
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE OR LOCAL REGULATIONS. INCINERATE.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR RESPIRABLE FUME RESPIRATOR/AIR SUPPLIED
RESPIRATOR WHEN WELDING IN CONFINED SPACE, WHERE LOCAL
EXHAUST/VENTILATION DOESN'T KEEP EXPOSURE < TLV.
Ventilation:LOCAL EXHAUST AT WORK AREA TO KEEP FUMES/GASES < TLV IN
WORKER'S BREATHING ZONE & GENERAL AREA.
Other Protective Equipment:W/FILTER LENS, APRON, HAT, SHOULDER
PROTECTION, ARM PROTECTORS, DARK SUBTANTIAL CLOTHING.
Supplemental Safety and Health
PRODUCT IS NON-HAZARDOUS UNTIL USED AS IN WELDING PURPOSES. THE
COMPOSITION & QUANTITY OF FUMES/GASES DEPENDS ON METAL BEING
WELDED, PROCESS, PROCEDURES, ELECTRODES USED, COATINGS, POSITION OF
WELDERS HEAD W/RESPECT TO THE PLUME & AS WELL AS THE PRESENCE OF
CONTAMINANTS IN THE ATMOSPHERE.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:GRAPHITE
Fraction by Wt: 2.5%
Other REC Limits:2.5MG/CUM
ACGIH TLV:2 MG/CUM RESP IC
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SHORT TERM EXPOSURE TO WELDING FUMES:
DIZZINESS, NAUSEA, DRYNESS, IRRITATION OF NOSE, THROAT/EYES. LONG
TERM EXPOSURE TO WELDING FUMES: RESPIRATORY PROBLEMS,
SIDEROSIS(IRON BUILD UP IN THE LUNGS)& AFF ECT THE PULMONARY
FUNCTION. ARC RAYS CAN INJURE EYES & BURN SKIN. ELECTRIC SHOCK CAN
KILL.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:SHORT TERM EXPOSURE TO WELDING FUMES:
DIZZINESS, NAUSEA, DRYNESS, IRRITATION OF THE NOSE, THROAT/EYES.
LONG TERM EXPOSURE TO WELDING FUMES: RESPIRATORY PROBLEMS,
SIDEROSIS(IRON BUILD UP IN THE LUNGS) & AFFECT THE PULMONARY
FUNCTION. ARC RAYS CAN INJURE EYES & BURN SKIN. ELECTRIC SHOCK CAN
KILL.
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY/ALLERGIC
CONDITIONS.
* First Aid Measures *
First Aid:IF OVERCOME BY SMOKE/FUMES, REMOVE TO FRESH AIR. SKIN: WASH
DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point:NON-FLAMMABLE
Unusual Fire/Explosion Hazard:WELDING ARC & SPARKS CAN IGNITE
COMBUSTIBLES & FLAMMABLE PRODUCTS.
* Accidental Release Measures *
Spill Release Procedures:COLLECT MATERIAL FOR RECLAMATION &
REUSE/DISPOSE IN SEALED CONTAINERS. KEEP AIRBORNE DUST AT A MINIMUM
WHEN CLEANING UP.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A TIGHTLY CLOSED CONTAINER IN
A COOL DRY PLACE. KEEP AWAY FROM EXTREME HEAT.
Other Precautions:AVOID CONTACT W/EYES, SKIN/CLOTHING. DON'T SMOKE,
EAT/DRINK IN WORK AREA. TRAIN WELDER NOT TO TOUCH LIVE ELECTRICAL
PARTS & INSULATE THEMSELVES FROM WORK & GROUND.
* Physical/Chemical Properties *
Appearance and Odor:DARK GRAY TO BLACK SOLID MATERIAL, NO ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE W/STRONG ACIDS.
Stability Condition to Avoid:EXTREMELY HIGH TEMPS
Hazardous Decomposition Products:CO, CO2, HIGH TEMPS
* Disposal Considerations *
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSABLE
CONTAINER/LINER IN AN ENVIRONMENTAL ACCEPTABLE MANNER IAW/FEDERAL,
STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Product ID:SANI-TREET
Preparer's Name:JOE PELLICANO
* Composition/Information on Ingredients *
Ingred Name:NON-HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: NAUSEA MAY FOLLOW INGESTION.
CHRONIC:
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NOT APPLICABLE.
* First Aid Measures *
First Aid:SEEK MEDICAL ASSISTANCE FOR FURTHER TREATMENT, OBSERVATION
AND SUPPORT IF NECESSARY. EYES: AVOID EYE CONTACT. RINSE EYES
COPIOUS AMOUNTS OF WATER. SEE MD . INHALATION: REMOVE TO FRESH
AIR. SUPPORT BREATHING (GIVE OXYGEN OR ARTIFICIAL RESPIRATION) .
INGESTION: DRINK PLENTY OF FLUIDS.
* Fire Fighting Measures *
Flash Point Method:TOC
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT APPLICABLE.
* Accidental Release Measures *
Spill Release Procedures:MOP UP.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:
Other Precautions:
* Physical/Chemical Properties *
Spec Gravity:1.0 (H*2O=1)
Appearance and Odor:PINK LIQUID WITH A LEMON-LIME ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NOT APPLICABLE.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:NOT APPLICABLE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF ON SITE. DISPOSE OF IN ACCORDANCE
W/LOCAL, STATE & FEDERAL REGULATIONS .
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE IN WELL-VENTILATED AREA WITH LOCAL EXHAUST. MECHANICAL
EXHAUST REQUIRED.
Other Protective Equipment:SAFETY SHOWER & EYE BATH. WEAR PROTECTIVE
CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
EXPLO HAZ: CNDTNS. FORMS EXPLO MIX IN AIR. EMITS TOX FUMES. FIRE HAZ OF
FRESH SOLN SLIGHT. IF LEFT SEVERAL HRS IN SHALLOW TRAY/IF CNTNR NOT
TIGHTLY CAPPED, FIRE HAZ BECOMES HIGH. EXPLAN OF CARCIN: ANT IC TO
BE CARCIN. ANIMAL:BLADDER CANCER,LIVER, SKIN EFTS.
* Product Identification *
Product ID:PHOTO ETCH PHOTORESIST DEVELOPER, ER-8
* Composition/Information on Ingredients *
Ingred Name:BLEND OF SOLVENTS CONTAINING INGS 2 & 4 PACKAGED IN 1 PINT
METAL CAN WITH SCREW CAP
Ingred Name:METHANE, DICHLORO-; (DICHLOROMETHANE) (SARA III) BP:
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:EFTS OF OVEREXP: METABOLIZED IN BODY PRODUCING CO WHICH
INCREASES & SUSTAINS CARBOXYHEMOGLOBIN LEVELS IN BLOOD, (ING 8)
Ingred Name:ING 7: REDUCING THE OXYGEN-CARRYING CAPACITY OF THE BLOOD.
Ingred Name:WASTE DISP METH: AS MATL IS HIGHLY FALMMABLE. OBSERVE ALL
FEDERAL, STATE & LOCAL LAWS.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: CHLOROCARBON MATLS HAVE PRDCED
SENSIT OF MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS & COULD HAVE
SIMILAR EFT IN HUMANS. ADRENOMIMETICS (EG, EPINEPHRINE) MAY BE
CONTRA-INDICATED EXCEPT FOR LIFE-SU STAINING USES IN HUMANS
ACUTELY/CHRONICALLY EXPOSED TO CHLOROCARBONS . HARMFUL IF
SWALLOWED, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:METHYLENE CHLORIDE:IARC MONOGRAPHS,
Effects of Overexposure:HLTH HAZ: INHALED/ABSORBED THRU SKIN. VAP/MIST
IS IRRIT TO EYES, MUC MEMB & UPPER RESP TRACT. CAUSES SKIN IRRIT.
EXPOS CAN CAUSE:NAUS, DIZZ & HDCH, NARCOTIC EFT, LUNG IRRIT, CHEST
PAIN & EDEMA WHICH M AY BE FATAL, CNS DEPRESS, DERM, GI & NERVOUS
SYS DISTURB. CHRONIC: DMG TO LIVER & KIDNEYS, BLOOD EFTS. ING 2 IS
(ING 7)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INGEST: CALL MD IMMED . SKIN: IMMED WASH W/SOAP & COPIOUS
WASH CONTAMD CLTHG BEFORE REUSE. EYES: IMMED IRRIGATE EYES
BY SEPARATING EYELIDS W/FINGERS. INHAL: REMOVE TO FRESH AIR. IF NOT
BRTHG GIVE ARTF RESP. IF BRTHG DFCLT, GIVE OXYGEN. CALL MD.
* Fire Fighting Measures *
Flash Point:SEE ING 1
Lower Limits:SEE INGS
Upper Limits:SEE INGS
Extinguishing Media:CARBON DIOXIDE, DRY CHEM POWDER, ALCOHOL/POLYMER
FOAM. WATER MAY BE EFTIVE FOR COOLING BUT MAY NOT EFT
EXTINGUISHMENT.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
AND FULL PROTECTIVE EQUIPMENT . FLAMMABLE. USE WATER SPRAY TO COOL
FIRE-EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:THERMAL DECOMP PRODS MAY INCL HCL &
PHOSGENE. VAP MAY TRAVEL CONSIDERABLE DIST TO SOURCE OF IGNIT &
FLASH BACK. CNTNR EXPLOS MAY OCCUR UNDER FIRE (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:EVAC AREA. SHUT OFF ALL SOURCES OF IGNIT. WEAR
W/ACTIVATED CARBON ABSORB. TAKE UP & PLACE IN CLSD CNTNRS FOR DISP.
TRANSPORT OUTDOORS. VEN T AREA & WASH SITE AFTER MATL PICKUP
ISCOMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:USE NONSPK TOOLS. PROD WILL DMG MOST
PAINTS & PLASTICS. KEEP TIGHTLY CLSD. KEEP AWAY FROM HEAT, SPKS &
OPEN FLAME. STORE IN COOL, DRY PLACE.
Other Precautions:NO SMKNG IN AREA OF USE. DO NOT USE IN GEN VICIN OF
ARC WELDING, OPEN FLAMES/HOT SURFS. HEAT &/OR UV RADIA MAY CAUSE
FORM OF HCL &/OR PHOSGENE . DO NOT BREATHE VAP. AVOID CNTCT W/EYES,
SKIN & CL THG. READILY ABSORBED THROUGH SKIN.
* Physical/Chemical Properties *
Boiling Pt:B.P. Text:SEE INGS
Melt/Freeze Pt:M.P/F.P Text:SEE INGS
Vapor Pres:SEE INGS
Vapor Density:SEE INGS
Spec Gravity:SEE INGS
Appearance and Odor:BLEND OF SOLVENTS PACKAGED IN 1 PINT METAL CAN WITH
SCREW CAP.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, ALKALI METALS, ALUMINUM, HEAT.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
HYDROGEN CHLORIDE GAS, PHOSGENE GAS.
* Disposal Considerations *
Waste Disposal Methods:MATL SHOULD BE IGNITED IN PRESENCE OF SODIUM
CARBONATE & SLAKED LIME (CALCIUM HYDROXIDE). IT SHOULD BE MIXED
W/VERMICULITE & THEN W/DRY CAUSTICS, WRAPPED IN PAPER & BURNED IN
CHEM INCIN EQUIPPED W/AFT ERBURNER & SCRUBBER BUT EXERT EXTRA CARE
(ING 9)
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:PERSONAL RESPIRATORS (NIOSH APPROVED) IF
EXPOSURE LIMIT IS EXCEEDED.
Ventilation:A SYSTEM OF LOCAL OR GENERAL EXHAUST IS RECOMMENDED TO KEEP
EMPLOYEE EXPOSURE BELOW THE AIRBORNE EXPOSURE LIMITS. LOCAL EXHAUST
VENTILATION IS PREFERRED.
SHIELD ARE ADVISED.
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING AND BOOTS. EYE WASH AND
QUICK-DRENCH FACILITIES SHOULD BE NEAR WORK AREA.
Work Hygienic Practices:NOT PROVIDED
Supplemental Safety and Health
UNIT QTY IS A KIT CONSISTING OF ONE 5 GALLON CAN OF PENETRANT AND TWO 5
GALLON CANS OF EMULSIFIER (MSDS SERIAL NUMBER: CLMPZ).
* Product Identification *
Kit Part:Y
Preparer's Name:NOT PROVIDED
* Composition/Information on Ingredients *
Ingred Name:HYDROTREATED MIDDLE DISTILLATE
Other REC Limits:NOT PROVIDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:POTENTIAL HEALTH EFFECTS: EYE CONTACT:
LIQUID MAY CAUSE IRRITATION, REDNESS, TEARING AND STINGING OF EYES.
SKIN CONTACT: MAY CAUSE SKIN IRRITATION WITH PROLONGED OR REPEATED
CONTACT. SYMPTOMS MAY INCL UDE REDNESS, BURNING, AND CRACKINK OF
SKIN. SWALLOWING: SMALL AMOUNTS MAY NOT PRODUCE HARMFUL EFFECTS.
LARGE AMOUNTS MAY BE HARMFUL. INHALATION: SMALL AMOUNTS MAY NOT BE
HARMFUL. LARGE AMOUNTS MAY BE HARMFUL.
Explanation of Carcinogenicity:THIS MATERIAL IS NOT KNOWN TO CONTAIN
ANY CONSTITUENTS LISTED AS A CARCINOGEN BY THE INTERNATIONAL AGENCY
FOR RESEARCH ON CANCER, THE NATIONAL TOXICOLOGY PROGRAM , OR OSHA.
Effects of Overexposure:STOMACH OR INTESTINAL UPSET (NAUSEA, VOMITING,
DIARRHEA), IRRITATION (NOSE, THROAT, AIRWAYS), CENTRAL NERVOUS
SYSTEM DEPRESSION (DIZZINESS, DROWSINESS, FATIGUE, HEADACHE,
UNCONSCIOUSNESS).
Medical Cond Aggravated by Exposure:NOT PROVIDED
* First Aid Measures *
HOLD EYELIDS OPEN. SEEK MEDICAL ATTENTION. SKIN: REMOVE
CONTAMINATED CLOTHING. WASH EXPOSED AREA WITH SOAP AND WATER. IF
SYMPTOMS PERSIST, SE EK MEDICAL ATTENTION. LAUNDER CLOTHING AND
CLEAN SHOES BEFORE REUSE. SWALLOWING: CALL A PHYSICIAN
IMMEDIATELY. IF INDIVIDUAL IS DROWSY OR UNCONSCIOUS, DO NOT GIVE
ANYTHING BY MOUTH; PLACE INDIVIDUAL ON THEIR LEFT SIDE WITH THE
HEAD DOWN. DO NOT LEAVE THE INDIVIDUAL UNATTENDED. INHALATION:
REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN. GET MEDICAL
ATTENTION IMMEDIATELY
* Fire Fighting Measures *
Flash Point Method:PMCC
Autoignition Temp:Autoignition Temp Text:N/AV
Lower Limits:N/AV
Upper Limits:N/AV
Extinguishing Media:DRY CHEMICAL, WATER FOG, FOAM, CARBON DIOXIDE
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE. WATER SPRAY MAY BE
USED TO KEEP FIRE EXPOSED CONTAINERS COOL. WEAR FULL PROTECTIVE
CLOTHING AND NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS WITH
FULL FACE PIECE OPERAT ED IN THE PRESSURE DEMAND OR OTHER POSITIVE
PRESSURE MODE.
Unusual Fire/Explosion Hazard:NONE KNOWN.
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA. REMOVE ALL SOURCES OF
IGNITION. ISOLATE AREA. WEAR PROTECTIVE GEAR, KEEP UNNECESSARY
PERSONNEL AWAY. CONTAIN AND RECOVER LIQUID WHEN POSSIBLE. COLLECT
LIQUID IN AN APPROPRIATE CONTAIN ER OR ABSORB WITH AN INERT
MATERIAL SUCH AS VERMICULITE, DRY SAND, OR EARTH; DO NOT USE
COMBUSTIBLE MATERIALS, AND PLACE IN A CHEMICAL WASTE CONTAINER. DO
NOT FLUSH TO SEWER!
Neutralizing Agent:NOT RELEVANT
*Handling and Storage *
Handling and Storage Precautions:PROTECT AGAINST PHYSICAL DAMAGE. STORE
IN A COOL, DRY WELL-VENTILATED LOCATION, AWAY FROM AREAS WHERE FIRE
HAZARD MAY EXIST. STORE AND USE IN NO SMOKING AREA.
Other Precautions:EMPTY CONTAINERS MAY CONTAIN RESIDUE LIQUID AND
VAPORS. ANY USE OF THIS PRODUCT IN ELEVATED TEMPERATURE PROCESSING
SHOULD BE THOROUGHLY EVALUATED TO ESTABLISH AND MAINTAIN SAFE
OPERATING CONDITIONS.
* Physical/Chemical Properties *
HCC:V4
NRC/State Lic Num:NOT RELEVANT
Melt/Freeze Pt:M.P/F.P Text:NOT PROVIDED
Decomp Temp:Decomp Text:NOT PROVIDED
Vapor Pres:NOT AVAILABLE
Vapor Density:N/AV
Viscosity:NOT PROVIDED
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:INSOLUBLE
Appearance and Odor:FLUORESCENT YELLOW-GREEN LIQUID; SLIGHT HYDROCARBON
ODOR
Percent Volatiles by Volume:NOT PROVIDED
Corrosion Rate:NOT PROVIDED
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:STABLE UNDER ORDINARY CONDITIONS OF USE
AND STORAGE.
Hazardous Decomposition Products:MAY FORM CARBON DIOXIDE AND CARBON
MONOXIDE.
* Toxicological Information*
Toxicological Information:NO DATA AVAILABLE ON PRODUCT.
* Ecological Information *
Ecological:NO DATA AVAILABLE ON PRODUCT.
* Disposal Considerations *
Waste Disposal Methods:PROCESSING, USE OR CONTAMINATION OF THIS PRODUCT
MAY CHANGE WASTE MANAGEMENT OPTIONS. STATE AND LOCAL DISPOSAL
REGUALTIONS MAY DIFFER FROM FEDERAL DISPOSAL REGUALTIONS. DISPOSE
OF CONTAINER AND UNUSED CONTENTS IN ACCORDANCE WITH FEDERAL, STATE
AND LOCAL REQUIREMENTS.
* MSDS Transport Information *
RQ: NOT APPLICABLE.
* Regulatory Information *
IMMEDIATE (X), DELAYED (X), FIRE ( ), REACTIVE ( ), SUDDEN RELEASE
Federal Regulatory Information:TSCA: LISTED.
FOLLOWING STATEMENT - PRODUCT MAY CONTAIN DETECTABLE AMOUNTS OF
SUBSTANCES KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT REQUIRED UNLESS WORKING IN AN AREA WITH
CONCENTRATIONS OF HEATED VAPORS.
Ventilation:NO SPECIAL REQUIREMENTS, UNLESS WORKING IN AN AREA WHERE
MATERIAL IS HEATED OR BURNED.
Other Protective Equipment:RUBBER APRON, IF HANDLING IN BULK
QUANTITIES.
Work Hygienic Practices:WASH HANDS AFETR HANDLING.
Supplemental Safety and Health
NONE
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:DISTILLATES, HYDROTREATED HEAVY PARAFFINIC
Other REC Limits: RECOMMENDED
Ingred Name:PROPRIETARY ADDITIVES
Other REC Limits: RECOMMENDED
Ingred Name:ZINC COMPOUNDS
Other REC Limits: RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE-MAY CAUSE TRANSIENT IRRITATION.
INHALATION-INHALATION OF HEATED VAPORS MAY CAUSE IRRITATION OF THE
LUNGS. INGESTION-MAY CAUSE GASTROINTESTINAL IRRITATION.
Explanation of Carcinogenicity:NOT CARCINOGENIC.
Effects of Overexposure:SKIN CONTACT-PROLONGED OR REPEATED SKIN CONTACT
MAY CAUSE IRRITATION, RASH OR DERMATITIS.
Medical Cond Aggravated by Exposure: SPECIFIED BY MANUFACTURER.
* First Aid Measures *
ATTENTION. SKIN-REMOVE ANY CONTAMINATED CLOTHING AS SOON AS
POSSIBLE. WASH EXPOSED SKIN THOROUGHLY WITH SOAP & WATER. GET
MEDICAL ATTENTION . INHALATION-REMOVE PERSON TO FRESH AIRIF
OVEREXPOSURE OCCURS. ADMINISTER ARTIFICIAL RESPIRATION SHOULD
BREATHING STOPS. INGESTION-DO NOT INDUCE VOMITING IF LARGE AMOUNTS
ARE SWALLOWED. SEE PHYSICIAN
* Fire Fighting Measures *
Flash Point Method:COC
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:
Unusual Fire/Explosion Hazard:
* Accidental Release Measures *
Spill Release Procedures:NOTIFY APPROPIATE AUTHORITIES OF SPILL.
CONTAIN SPILL IMMEDIATELY. DO NOT ALLOW SPILL TO ENTER SEWERS OR
WATER COURSES. ABSORB WITH APPROPIATE INERT MATERIAL SUCH AS SAND,
CLAY, ETC. LARGE AMOUNTS MAY PICKED UP USING VACUUM PUMPS & PLACE
IN DRUMS.
Neutralizing Agent: SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DO NOT TRANSFER TO UNMARKED
CONTAINERS. STORE IN CLOSED CONTAINERS AWAY FROM HEAT, SPARKS, OPEN
FLAMES, OR OXIDIZING MATERIALS.
Other Precautions:THIS PRODUCT IS NOT CLASSIFIED AS HAZARDOUS UNDER DOT
REGULATIONS. FIRE EXTINGUISHERS SHOULD BE KEPT READILY AVAILABLE.
* Physical/Chemical Properties *
HCC:V6
Vapor Pres:NA
Vapor Density:>1
Spec Gravity:0.9
Evaporation Rate & Reference:NIL
Solubility in Water:NIL
Appearance and Odor:AMBER LIQUID WITH OILY ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE AND
NOXIOUS SMOKE.
* Disposal Considerations *
Waste Disposal Methods:ALL DISPOSAL MUST COMPLY WITH FEDERAL, STATE AND
LOCAL REGULATIONS. CAUTION! SHOULD REGULATED SOLVENTS BE USED TO
CLEAN UP SPILLED MATERIAL, THE RESULTING WASTE MIXTURE MAY BE
REGULATED. MATERIAL MAY BE RECYCLED IF POSSIBLE.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:FOR USE W/SOLIDS (NOT REQD FOR LIQS): IF EXPOS
LIM IS EXCEEDED, A NIOSH APPRVD HALF-FACE RESP WITH DUST/MIST RESP
APPROP REGULATORY A GENCY/RESP SUPPLIER, WHICHEVER IS LOWEST. A
TIMES EXPOS LIM/MAX USE CONC SPECIFIED (OTHER INFO)
Ventilation:SYS OF LOC &/OR GEN EXHST IS REC TO KEEP EMPLOYEE EXPOS
BELOW AIRBORNE EXPOS LIMS. LOC EXHST VENT IS GENRLY PREF BECAUSE IT
CAN CONTROL EMISSIONS OF(SUPP DATA)
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
WEAR CLEAN BODY-COVERING CLOTHING, INCLUDING LAB COAT.
Work Hygienic Practices:AS PART OF GOOD INDUSTRIAL AND PERSONAL HYGIENE
AND SAFETY PROCEDURE, AVOID ALL UNNECESSARY EXPOSURE TO CHEMICAL
SUBSTANCE AND ENSURE PROMPT REMOVAL FROM SKIN, EYES AND CLOTHING.
Supplemental Safety and Health
SPILL PROC:PLACE IN CHEM WASTE CNTNR. DO NOT USE COMBUST MATLS, SUCH AS
SAW DUST. DO NOT FLUSH TO SEWER. -- VENT:CONTAM AT ITS SOURCE,
PREVENTING DISPERSION OF IT INTO GEN WORK AREA. PLEASE REFER TO A
CGIH DOCUMENT, "INDUS VENT, A MANUAL OF REC PRACTICES," MOST RECENT
EDITION, FOR DETAILS.
* Product Identification *
* Composition/Information on Ingredients *
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: NO ADVERSE HEALTH
EFFECTS EXPECTED FROM INHALATION. (MAY BE A MECHANICAL IRRITANT).
INGESTION: LARGE DOSES OF THE LOWER MOLECULAR WEIGHT PRODUCTS MAY
CAUSE GASTRO-INTESTINAL UPSET. SKIN CONTACT: NO ADVERSE EFFECTS
EXPECTED. EYE CONTACT: NO ADVERSE EFFECTS EXPECTED. CHRONIC: NO
INFORMATION FOUND.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:DAMAGED SKIN.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
O*2/ARTF RESP) . INGESTION: IF LARGE AMOUNTS WERE SWALLOWED, GIVE
WATER TO DRINK AND GET MEDICAL ADVICE. SKIN: IMMEDIATELY FLUSH WITH
CONTAMINATED CLOTHING AND SHOES. WASH CLOTHING BEFORE REUSE. GET
MEDICAL ATTENTION IF IRRITATION DEVELOPS OR PERSISTS. EYES: FLUSH
IF IRRITATION DEVELOPS.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, DRY CHEMCIAL, ALCOHOL FOAM, OR CARBON
DIOXIDE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:FIRE: AS WITH MOST ORGANIC SOLIDS, FIRE
IS POSSIBLE AT ELEVATED TEMPS OR BY CONTACT WITH IGNITION SOURCE.
(INCREASES AS MOLECULAR WEIGHT INCREASES). EXPLO: FINE DUST
DISPERSED IN AIR IN SUFFICIENT CON CS, & IN PRESENCE OF IGNIT
SOURCE IS POTNTL DUST EXPLO HAZ. NFPA RATINGS: HEALTH - 0;
FLAMMABILITY - 1; REACTIVITY - 0.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT. VENT AREA OF
LEAK/SPILL. WEAR APPROP PPE AS SPECIFIED IN THIS MSDS. SOLID
SPILLS: CLEAN UP SPILLS IN A MANNER THAT DOES NOT DISPERSE DUST
INTO AIR. USE NON-SPARKING TOOLS & EQUIP. REDUCE AIRBORNE DUST &
PVNT SCATTERING BY MOISTENING W/WATER. PICK UP SPILL FOR
RECOVERY/DISP & PLACE IN CLSD CNTNR. LIQ SPILLS: ABSORB
W/VERMICULITE, DRY SAND, EARTH/SIMILAR MATL & (SUPDAT)
*Handling and Storage *
Handling and Storage Precautions:STORAGE COLOR CODE: ORANGE (GENERAL
STORAGE). KEEP IN A TIGHTLY CLOSED CONTAINER, STORED IN A COOL,
DRY, VENTILATED AREA. PROTECT AGAINST PHYSICAL DAMAGE.
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTY SINCE THEY RETAIN PRODUCT RESIDUES (DUST, SOLIDS, VAPORS,
LIQUID); OBSERVE ALL WARNINGS AND PRECAUTIONS LISTED FOR THIS
PRODUCT.
* Physical/Chemical Properties *
Boiling Pt:B.P. Text:NO INFORMATION FOUND
Melt/Freeze Pt:M.P/F.P Text:SEE OTHER INFO
Vapor Pres:SEE OTHER INFO
Vapor Density:NO INFO
Spec Gravity:2.2-2.3 (SEE OTHER INFO)
pH:NO INFO FOUND
Evaporation Rate & Reference:NO INFORMATION FOUND
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR LIQUID OR WHITE SOLID; MILD ODOR.
Percent Volatiles by Volume:NO INFO
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE WITH POLYMERIZATION CATALYSTS (PEROXIDES, PERSULFATES) AND
ACCELERATORS, STRONG OXIDIZERS, STRONG BASES AND STRONG ACIDS.
Stability Condition to Avoid:INCOMPATIBLE. STABLE UNDER ORDINARY
CONDITIONS OF USE AND STORAGE.
Hazardous Decomposition Products:CARBON DIOXIDE AND CARBON MONOXIDE MAY
FORM WHEN HEATED TO DECOMPOSITION.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Toxicological Information*
AS A TUMORIGEN.
* Ecological Information *
Ecological:ENVIRONMENTAL FATE AND TOXICITY: NO INFORMATION FOUND.
* Disposal Considerations *
Waste Disposal Methods:WHATEVER CANNOT BE SAVED FOR RECOVERY OR
RECYCLING SHOULD BE MANAGED IN APPROPRIATE & APPROVED WASTE
DISPOSAL FACILITY. PROCESSING, USE OR CONTAMINATION OF THIS PRODUCT
MAY CHANGE WASTE MANAGEMENT OPT IONS. STATE & LOCAL DISPOSAL
REGULATIONS MAY DIFFER FROM FED DISPOSAL REGS. DISPOSE OF CNTNR &
UNUSE D CONTENTS I/A/W FED, STATE & LOCAL REQUIREMENTS.
* MSDS Transport Information *
Transport Information:NOT REGULATED.
* Regulatory Information *
PRESSURE - NO. REACTIVITY - NO. (PURE/SOLID).
TSCA & JAPAN - YES; EC & AUSTRALIA - NO; KOREA, DSL - YES; NDSL -
CODE: NO INFORMATION FOUND. POISON SCHEDULE: NO INFORMATION FOUND.
WHMIS: THIS MSDS HAS BEEN PREPARED ACCORDING TO HAZARD CRITERIA OF
CONTROLLED PRODUCTS REGS (CPR) & MSDS CONTAINS ALL OF THE
INFORMATION REQUIRED BY CPR.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR WITH A DUST
Ventilation:USE LOCAL EXHAUST TO MAINTAIN EXPOSURE BELOW PEL/TLV.
Other Protective Equipment:PROTECTIVE CLOTHING TO PREVENT SKIN CONTACT.
HAVE EYE WASH STATION & SAFETY SHOWER AVAILABLE.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:TETRASODIUM ETHYLENE DIAMINE TETRAACETATE
Fraction by Wt: 2-7%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NON HAZARDOUS INGREDIENTS
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION MAY CAUSE
RESPIRATORY IRRITATION. CONTACT WITH EYES MAY CAUSE IRRITATION.
INGESTION MAY CAUSE GI TRACT IRRITATION. CHRONIC: PROLONGED OR
REPEATED EXPOSURE MAY CAUSE SKIN IRRITATION O R BURNING.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:INHALED: HEADACHE, DIZZINESS, NAUSEA, SHORTNESS
OF BREATH, COUGHING, SNEZZING. EYES: BURNING, REDNESS, TEARING.
SKIN: REDNESS, ITCHING, DISCOMFORT, BURNING. INGESTED: NAUSEA,
VOMITING, DIARRHEA.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHALED: REMOVE TO FRESH AIR. GIVE OXYGEN IF BREATHING
DIFFICULT. GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. EYES: FLUSH
SKIN: REMOVE CON TAMINATED CLOTHES. WASH WITH SOAP AND WATER.
INGESTED: DO NOT INDUCE VOMITING! GIVE WATER TO DILUTE AND GET
MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:CARBON DIOXIDE, WATER, FOAM. MEDIA APPROPRIATE FOR
SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP AND DISPOSAE OF IN AN APPROVED MANNER
PREVENTING DISCHARGE TO THE ENVIRONMENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER. HMIS: SODIUM
BICARBONATE SOLUTION.
*Handling and Storage *
Handling and Storage Precautions:STORE DRUMS IN A COOL, DRY PLACE, BUNG
UP AND CLOSED TIGHTLY. STORE AWAY FROM STRONG ALKALIS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:N1
pH:>1.2
Appearance and Odor:BROWN POWDER; NO ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIS
Stability Condition to Avoid:AVOID CONTACT WITH BASES/ALKALIS.
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. IF MATERIAL IS NOT SALVAGED, NEUTRALIZE AND
DISCHARGE TO A TREATMENT SYSTEM.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NORMALLY REQUIRED.
CHANGES PER HOUR). MATCH RATE TO CONDITIONS.
Other Protective Equipment:EYE BATH, WASHING FACILITIES, SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:WATER
Other REC Limits: RECOMMENDED
Ingred Name:POTASSIUM SULFITE
Fraction by Wt: 1-5%
Other REC Limits: RECOMMENDED
Ingred Name:POTASSIUM CARBONATE
Fraction by Wt: 1-5%
Other REC Limits: RECOMMENDED
Ingred Name:DIETHYLENE GLYCOL
Fraction by Wt: 1-5%
Other REC Limits: RECOMMENDED
Ingred Name:1,3,5-TRINITROBENZENE (SARA III)
Fraction by Wt: <1%
Other REC Limits: RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION- LOW HAZARD FOR RECOMMENDED
HANDLING. EYES- CAUSES IRRITATION.SKIN- CAUSES IRRITATION. MAY
CAUSE ALLERGIC SKIN REACTION. INGESTION- EXPECTED TO BE A LOW
INGESTION HAZARD.
Effects of Overexposure: SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure: SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHALATION- IF SYMPTOMATIC, MOVE TO FRESH AIR. EYES- WASH
ATTENTION.SKIN- WASH WITH SOAP (NON-ALKALINE TYPE OF SKIN
CLEANER) AND WATE R. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION- DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point:
Extinguishing Media:ANY MEDIA SUITABLE FOR SURROUNDING MATERIAL.
Fire Fighting Procedures:
Unusual Fire/Explosion Hazard:
* Accidental Release Measures *
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER.
WITH VERMICULITE OR OTHER INERT MATERIAL, THEN PLACE IN A CONTAINER
FOR CHEMICAL WASTE. CLEAN SURFACE THOROUGHLY TO REMOVE
CONTAMINATION.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED.
Other Precautions:KEEP FROM CONTACT WITH OXIDIZING MATERIALS.
* Physical/Chemical Properties *
HCC:B3
Vapor Density:0.6
Spec Gravity:>1
Solubility in Water:COMPLETE
Appearance and Odor:TAN LIQUID. COLORLESS. ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
WITH COMMON MATERIALS AND CONTAMINANTS WITH WHICH THE MATERIAL MAY
REASONABLY COME INTO CONTACT.
Stability Condition to Avoid: SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
OXIDES OF SULFUR.
* Disposal Considerations *
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE, OR LOCAL LAWS. FLUSH TO SEWER WITH LARGE
AMOUNTS OF WATER.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:LOCAL EXHAUST
Supplemental Safety and Health
KIT(2 PART SYSTEM)
* Product Identification *
Product ID:DEFTHANE
* Composition/Information on Ingredients *
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
Ingred Name:ETHYL ACETATE (SARA III)
Ingred Name:2-ETHOXYETHYL ACETATE (CELLOSOLVE ACETATE) (EGEEA)
Ingred Name:TOLUENE (SARA III)
* Hazards Identification *
Effects of Overexposure:EYE,THROAT,SKIN,LUNG IRRITANT,NARCOSIS
* First Aid Measures *
First Aid:WASH SKIN THOROUGHLY FLUSH EYES WITH WATER,REMOVE TO FRESH
AIR,REMOVE CONTAMINATED CLOTHING GIVE ARTIFICIAL RESPIRATION IF
NEEDED,CALL DOCTOR
* Fire Fighting Measures *
Extinguishing Media:FOAM,DRY CHEMICAL,CARBON DIOXIDE
Unusual Fire/Explosion Hazard:AVOID FIRE,HEAT,SPARKS,IGNITION
SOURCES,STORAGE IN DIRECT SUNLIGHT
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA MECHANICALLY,KEEP FROM
FLAME,FIRE,SPARKS,IGNITION SOURCES;DO NOT BREATHE VAPORS;CLEAN UP
WITH ABSORBENT MATERIAL
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINERS CLOSED,UPRIGHT,AWAY
FROM FIRE,FLAME,SPARKS,IGNITION SOURCES,DIRECT SUNLIGHT
Other Precautions:AVOID PROLONGED BREATHING OF VAPORS
* Physical/Chemical Properties *
HCC:F2
Solubility in Water:NEGLIGIBLE
Appearance and Odor:FLAT,GREEN PAINT,PUNGENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:SANITARY LANDFILL,KEEP IN CLOSED CONTAINERS
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:HOOD.
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC:PATIENT IS HAVING DFCLTY BRTHG. IF PATIENT HAS STOPPED
BRTHG ADMIN ARTF RESP. IF PATIENT IS IN CARD ARREST ADMIN CPR.
CONTINUE LIFE SUPPORTING MEASURES UNTIL MED ASSISTANCE HAS ARRIVED.
GET MED ATTN IF NEC. DO NOT WEAR SHOES/CLTHG UNTIL ABSOLUTELY FREE
OF ALL CHEMICAL ODORS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:BUTYRIC ACID, BUTYL ESTER; (BUTANOIC ACID BUTYL ESTER)
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT LENSES SHOULD NOT BE WORN IN
THE LABORATORY. ALL CHEMICALS SHOULD BE CONSIDERED HAZARDOUS-AVOID
DIRECT PHYSICAL CONTACT! ACUTE:CAN BE HARMFUL IF INHALED. CAN BE
HARMFUL IF SWALLOWED. CAN BE HA RMFUL IF ABSORBED THROUGH THE SKIN.
CANCAUSE EYE IRRITATION. CAN CAUSE SKIN IRRITATION. DUST AND/OR
(EFTS OF OVEREEXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:VAPORS CAN CAUSE IRRITATION TO
RESPIRATORY TRACT. CAN BE IRRITATING TO MUCOUS MEMBRANES.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:ANTIDOTE IS SUBSTANCE INTENDED TO COUNTERACT EFT OF A POIS.
IT SHOULD ADMIN ONLY BY PHYS/TRAINED EMER PERS. MED ADVICE CAN BE
OBTAINED FROM A POIS CTL CTR. INGEST:CALL MD IMMEDIATELY .
TO CLEANSE SKIN. INHAL:REMOVE PATIENT TO FRESH AIR. ADMIN OXYG IF
(SUPDAT)
* Fire Fighting Measures *
Extinguishing Media:COMBUSTIBLE. CARBON DIOXIDE, DRY CHEMICAL POWDER OR
WATER SPRAY.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:THIS IS A COMBUSTIBLE COMPOUND.
* Accidental Release Measures *
Spill Release Procedures:EVAC AREA. WEAR APPROP OSHA-REGULATED EQUIP.
VENTILATE AREA. SWEEP UP & PLACE IN AN APPROP CNTNR. HOLD FOR
DISPOSAL. WASH CONTAMD SURFACES TO REMOVE ANY RESIDUES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:USE APPROP NIOSH/MSHA APPRVD SFTY
EQUIP. AVOID CONT W/SKIN, EYES & CLTHG. KEEP TIGHTLY CLSD & STORE
IN COOL DRY PLACE. STORE ONLY W/COMPAT CHEMICALS.
Other Precautions:PERSONS NOT SPECIFICALLY & PROPERLY TRAINED SHOULD
NOT HNDL THIS CHEM/ITS CNTNR. THIS PROD IS FURNISHED FOR LAB USE
ONLY! OUR PRODS MAY NOT BE USED AS DRUGS, COSMETICS,
AGRICULTURAL/PESTICIDAL PRODS, FOOD ADDITIVES/AS HOUSEHOLD
CHEMICALS.
* Physical/Chemical Properties *
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:INSOL (IMMISICIBLE)
Appearance and Odor:COLORLESS LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG BASES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:DECOMPOSITION LIBERATES TOXIC FUMES.
* Disposal Considerations *
Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. DISPOSAL MUST BE I/A/W FEDERAL, STATE &
LOCAL REGULATIONS .
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE SELF-CONTAINED BREATHING APPARATUS IF IN
CONFINED AREAS.
Ventilation:USE MECHANICAL VENTILATION TO CONTROL BELOW TLV.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
III)
Ozone Depleting Chemical:1
Ingred Name:CARBON DIOXIDE
Fraction by Wt: 3%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:UNKNOWN Ingestion:NO
Health Hazards Acute and Chronic:SUFFOCATION BY HEAVIER-THAN-AIR VAPOR
DISPLACING AIR.
Effects of Overexposure:LIGHT HEADEDNESS,GIDDINESS,SHORTNESS OF BREATH
& NARCOSIS,CARDIAC IRREGULARITIES,UNCONSCIOUSNESS OR DEATH.
REPEATED CONTACT CAN CAUSE SKIN IRRITATION.
* First Aid Measures *
WATER; INH:REMOVE TO FRESH AIR,USE ARTIFICIAL RESPIRATION OR OXYGEN
IF NECESSARY; ING:LOW ORAL TOXICITY,DO NOT INDUCE VOMITING,SEE A
PHYSICIA N IF NECESSARY.
* Fire Fighting Measures *
Extinguishing Media:USE PROPER MEDIA FOR SURROUNDING FIRE.
Fire Fighting Procedures:VENTILATE AREA WELL;TOXIC GASES EMITTED UPON
EXPOSURE TO FIRE.
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA,DIKE SPILL.ABSORB WITH INERT
ABSORBENT,STORE IN SEALED DRUMS FOR DISPOSAL.
*Handling and Storage *
Other Precautions:AVOID EXPOSURE OF PERSONS WITH CARDIOVASCULAR
DISEASE.
* Physical/Chemical Properties *
HCC:V2
Vapor Density:6.5
Evaporation Rate & Reference:0.1 (BUTYL ACETATE =1)
Appearance and Odor:CLEAR LIQUID,SWEET ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ALUMINUM,BERYLLIUM,ZINC & ALKALINE EARTH METALS.
Hazardous Decomposition Products:HYDROCHLORIC & HYDROFLUORIC ACIDS,IN
PRESENCE OF FLAME.
* Disposal Considerations *
Waste Disposal Methods:AUTHORIZED INCINERATOR OR RECLAIMER.
| 1 | gloves_mandatory |
Control Measures
*
*
Item Description Information
*
Item Manager: S9G
Item Name: DESICCANT,ACTIVATED
Unit of Issue: DR
UI Container Qty: 0
Type of Container: DRUM
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: THE DESSICANT PROPERTIES OF THIS PRODUCT MAY CAUSE
IRRITATION TO THE EYES & UPPER RESPIRATORY TRACT. ALUMINA IS A LOW HEALTH
RISK BY INHALATION & SHOULD BE TREATED AS A NUISANCE DUST AS SPECIFIED BY
T HE AMERICAN CONFERENCE OF GOVERNMENTAL INDUSTRIAL HYGENISTS.
Explanation Of Carcinogenicity: MANUFACTURER GAVE NO INFORMATION ABOUT
CARCINOGENICITY. FOUND NO LISTING & DOES NOT EXPECT IT TO BE
CARCINOGENIC.
Medical Cond Aggravated By Exposure: MFR GAVE NO INFORMATION OF MSDS.
First Aid: IF IRRITATION PERSISTS OR IS SEVERE, GET MEDICAL ATTENTION.
FROM EXPOSURE. AID OR RESTORE BREATHING AS NEEDED. INGESTED:DILUTE W/ LARGE
AMOUNTS OF WATER. DO NOT INDUCE VOMITING. GET IMMEDIATE MEDICAL ATTENTION.
*
Handling and Disposal
*
Spill Release Procedures: USE DRY CLEANUP PROCEDURES, AVOID DUSTING. COLLECT IN
CONTAINERS OR BAGS.
Neutralizing Agent: MFR GAVE NO INFORMATION OF MSDS.
Waste Disposal Methods: IF REUSE OR RECYCLING IS NOT POSSIBLE, MATERIAL MAY BE
DISPOSED OF AT A SANITARY LANDFILL.
Handling And Storage Precautions: MFR GAVE NO INFORMATION OF MSDS.
Other Precautions: MFR GAVE NO INFORMATION OF MSDS.
*
Fire and Explosion Hazard Information
*
Flash Point Text: NON-FLAMMABLE
Autoignition Temp Text: N/K.
Lower Limits: UNKNOWN
Upper Limits: UNKNOWN
Extinguishing Media: MFR GAVE NO INFORMATION OF MSDS.
Fire Fighting Procedures: WEAR SELF-CONTAINED BREATHING APPARATUS W/FULL
FACEPIECE OPERATED POSITIVE PRESSURE & FULL PROTECTIVE CLOTHING WHEN
APPROPRIATE.
Unusual Fire/Explosion Hazard: MFR GAVE NO INFORMATION OF MSDS.
*
*
Respiratory Protection: WHERE EXPOSURE LIMIT IS OR MAY BE EXCEEDED, USE
NIOSH-APPROCED RESPIRATORY PROTECTION. SELECT THE APPROPRIATE RESPIRATOR
(DUST RESPIRATOR) BASED ON THE ACTUAL OR POTENTIAL AIRBORNE CONTAMINANTS
& THEI R CONCENTRATIONS PRESENT.
Ventilation: USE W/ADEQUATE VENTILATION TO MEET EXPOSURE LIMITS.
Other Protective Equipment: MFR GAVE NO INFORMATION OF MSDS.
Work Hygienic Practices: MFR GAVE NO INFORMATION OF MSDS.
Supplemental Safety and Health: NONE
*
Physical/Chemical Properties
*
HCC: N1
NRC/State LIC No: NONE
B.P. Text: N/A.
Decomp Text: UNKNOWN
Vapor Pres: N/A.
Vapor Density: N/A.
Spec Gravity: 3.2
Viscosity: UNKNOWN
Evaporation Rate & Reference: N/A.
Solubility in Water: INSOLUBLE
Appearance and Odor: OFF-WHITE, CRYSTALLINE OR GELATINOUS GRANULES, PELLETS,
POWDER - NO ODOR
Corrosion Rate: UNKNOWN
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: RISE IN TEMPERATURE MAY OCCUR FROM CONTACT WITH
WATER.
Materials To Avoid: MFR GAVE NO INFORMATION ON MSDS.
Hazardous Decomposition Products: MFR GAVE NO INFORMATION ON MSDS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: WILL NOT OCCUR.
*
Toxicological Information
*
*
Ecological Information
*
*
*
Transport Information: NOT REGULATED
*
Regulatory Information
*
*
Other Information
*
*
Transportation Information
*
Tech Entry NOS Shipping Nm: NONE
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: DR
Container QTY: 0
Type Of Container: DRUM
*
Detail DOT Information
*
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail IMO Information
*
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
*
Detail IATA Information
*
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail AFI Information
*
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
HAZCOM Label
*
Company Name: ALUMINUM CO OF AMERICA,VIDALIA WORKS
Label Required IND: Y
Status Code: C
MFG Label NO: NONE
Origination Code: F
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: None
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: THE DESSICANT PROPERTIES OF THIS PRODUCT MAY CAUSE
IRRITATION TO THE EYES & UPPER RESPIRATORY TRACT. ALUMINA IS A LOW HEALTH
RISK BY INHALATION & SHOULD BE TREATED AS A NUISANCE DUST AS SPECIFIED BY
T HE AMERICAN CONFERENCE OF GOVERNMENTAL INDUSTRIAL HYGENISTS. MFR GAVE NO
INFORMATION OF MSDS.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:AS REQUIRED IF PROPER VENTILATION IS MAINTAINED.
Ventilation:LOCAL EXHAUST IS PREFERRED & MECHANICAL VENTILATION IS
ADEQUATE.
Other Protective Equipment:IMPERVIOUS CLOTHING
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING. HANDLE W/DUE
CARE. WASH HANDS & FACE BEFORE EATING, DRINKING & SMOKING.
Supplemental Safety and Health
* Product Identification *
Product ID:FIEBING'S ANTIQUE FINISH (ALL STANDARD COLORS)
* Composition/Information on Ingredients *
Ingred Name:BENZIN, NAPHTHA, MINERAL SPIRITS
Ingred Name:TERPENE HYDROCARBON
Fraction by Wt: 8%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/INGESTION: IRRITATION. SKIN:
IRRITATION & DERMATITIS. INHALATION: CENTRAL NERVOUS
SYSTEM/RESPIRATORY/NOSE IRRITATION, LIGHT-HEADEDNESS & DROWSINESS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES/INGESTION: IRRITATION. SKIN: IRRITATION &
DERMATITIS. INHALATION: CENTRAL NERVOUS SYSTEM/RESPIRATORY/NOSE
IRRITATION, LIGHT-HEADEDNESS, & DROWSINESS.
* First Aid Measures *
WASH W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. GIVE CPR OR
OXYGEN IF NEEDED. INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point:NON-FLAMMABLE
Extinguishing Media:DRY CHEMICAL, FOAM, CO2 & WATER SPRAY (FOG)
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE, NUT CAN BE
USED TO KEEP CONTAINERS COOL.
Unusual Fire/Explosion Hazard:A VAPOR ACCUMULATION WOULD FLASH &
EXPLODE IF IGNITED.
* Accidental Release Measures *
Spill Release Procedures:ELMINATE SOURCES OF IGNITION. VENTILATE.
ABSORB W/APPROPRIATE MATERIAL.
*Handling and Storage *
Handling and Storage Precautions:STORE W/CONTAINER CLOSED IN COOL, DRY,
VENTILATED AREA.
Other Precautions:KEEP AWAY FROM SOURCES OF IGNITION & FREEZING. AVOID
SKIN & EYE CONTACT. KEEP OUT OF REACH OF CHILDREN.
* Physical/Chemical Properties *
Spec Gravity: 0.9
Solubility in Water:SOLUBLE
Appearance and Odor:COLORED PASTES W/CHARACTERISTIC HYDROCARBON ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, SOURCES OF IGNITION, & FREEZING.
Hazardous Decomposition Products:CO, CO2 & OTHER OXIDES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE,
FEDERAL, & COUNTY REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR SPECIFIED FOR
PROTECTION AGAINST PAINT SPRAY MIST, SANDING DUST AND ORGANIC
VAPORS IN RESTRICTED OR CONFINED AREAS.
Ventilation:ADEQ TO MAINTAIN WORKING ATM BELOW T.L.V. & L.E.L. MECH
EXHAUST MAY BE REQD IN CONFINED AREAS. DISCHARGE (SUPP DATA)
Other Protective Equipment:CLOTHING ADEQUATE TO PROTECT SKIN.
Work Hygienic Practices:REMOVE AND WASH CLOTHING BEFORE REUSE. WASH
HANDS BEFORE EATING, SMOKING OR USING WASHROOM.
Supplemental Safety and Health
SOURCES.
* Product Identification *
* Composition/Information on Ingredients *
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
Fraction by Wt: 0.6%
OSHA PEL:SEE TABLE Z3
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
Fraction by Wt: 6%
Ingred Name:CARBONIC ACID, CALCIUM SALT (1:1); (CALCIUM CARBONATE)
OSHA PEL:N/K
ACGIH TLV:N/K
Fraction by Wt: 2.3%
Ingred Name:CLAY (KAOLIN); (HYDROUS ALUM SILICATES)
Fraction by Wt: 7.6%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: HARMFUL, MAY AFFECT
BRAIN/NERV SYS, CAUSING DIZZ, HDCH/NAUS. EYE: CAUSES IRRIT. SKIN:
CAUSES IRRIT. INGEST: IRRIT OF DIGEST TRACT & NERV SYS DEPRESS
(DROW, DIZZ, LOSS OF COORD & FATG). A SPIR HAZ-MATL CAN ENTER LUNGS
DURING SWALLOWING OR VOMIT & CAUSE LUNG INFLAMM & DAM. CHRONIC:
SKIN: (EFTS OF OVEREXP)
Explanation of Carcinogenicity:CRYSTALLINE SILICA(QUARTZ):ANTIC TO BE
Effects of Overexposure:HLTH HAZ: PRLNGD/RPTD EXPOS MAY CAUSE DERM.
INHAL: SANDING DUST INHAL MAY CAUSE LUNG DAM. NOTE: RPTS HAVE ASSOC
PERM BRAIN & NERV SYS DAM W/RPTD, PRLNGD OVEREXP TO SOLV AMONG
PERSONS ENGAGED IN PAINTI NG TRADE. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING AND INHALING CONTENTS MAY BE
HARMFUL/FATAL.
Medical Cond Aggravated by Exposure:NONE EXPECTED WHEN USED IN
ACCORDANCE WITH SAFE HANDLING AND USE INFORMATION.
* First Aid Measures *
First Aid:INHAL: REMOVE FROM HAZARD AREA, MAINTAIN BREATHING, CALL
PHYSICIAN. SKIN: REMOVE WITH SOAP AND WATER. EYE: FLUSH IMMEDIATELY
PHYSICIAN. INGEST : DRINK 1-2 GLASSES OF WATER TO DILUTE.DO NOT
INDUCE VOMITING. CALL PHYSICIAN.
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:1%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP. DO
NOT USE WATER STREAM ON BURNING LIQUID. COOL EXPOSED CONTAINERS
W/WATER.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY BURST IF EXPOSED TO
EXTREME HEAT/FIRE. TOXIC GASES MAY FORM WHEN PRODUCT BURNS.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
BREATHING VAPORS. USE NON-SPARKING TOOLS TO RETURN MATERIALS TO
CONTAINER. ABSORB RESIDUE W/FULLER'S EARTH.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:FLAMMABLE-KEEP AWAY FROM HEAT, SPARKS
AND FLAME.
Other Precautions:USE ONLY W/ADEQ VENT. AVOID PRLNGD CONT W/SKIN &
BRTHG OF VAP SPRAY MIST/SANDING DUST. CLOSE CONTAINER AFTER EACH
USE. KEEP OUT OF REACH OF CHILDREN. DO NOT TAKE INTERNALLY.
* Physical/Chemical Properties *
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:ELEVATED TEMPERATURES AND BUILD UP OF
VAPORS.
Hazardous Decomposition Products:BURNING MAY PRODUCE CARBON DIOXIDE AND
CARBON MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:CONVENTIONAL PROCEDURES IN COMPLIANCE WITH
LOCAL, STATE AND FEDERAL REGULATIONS. DO NOT INCINERATE SEALED
CONTAINERS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . USE SCBA IN INADEQUATELY VENTILATED AREAS.
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Other Protective Equipment:AS REQUIRED TO AVOID WETTING CLOTHES.
Work Hygienic Practices:N/K
Supplemental Safety and Health
N/K
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
Fraction by Wt: 5%
Other REC Limits:
Ingred Name:ALIPHATIC HYDROCARBONS(VM & P NAPHTHA).ACGIH TLV IS FOR VM
& P NAPHTHA
OSHA PEL:
ACGIH TLV:
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:OVEREXPOSURE CAN DAMAGE LIVER &
KIDNEYS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:.INGESTION:.SKIN:N/K
.INHALATION:VAPOR MAY AFFECT CNS & CAUSE RESPIRATORY IRRITATION.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:INGESTION:DO NOT INDUCE VOMITING.CALL PHYSICIAN.SKIN:WASH W/
MIN.INHALATION:PROVIDE FRESH AIR & REST.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1.0
Upper Limits:6.5
Extinguishing Media:ALCOHOL FOAM,DRY CHEMICAL,CO*2.
Fire Fighting Procedures:DO NOT USE A STRAIGHT WATER STREAM WHICH COULD
SPREAD FIRES & COULD CAUSE FROTHING.USE NIOSH/MSHA APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:A VAPOR ACCUMULATION WOULD FLASH &/OR
EXPLODE IF IGNITED.HAZ DECOMP PROD:CARBON MONOXIDE IF BURNED WITH
INSUFFICIENT AIR.
* Accidental Release Measures *
Spill Release Procedures:AVOID OPEN FLAME.PROVIDE ADEQUATE
VENTILATION.COLLECT & DISPOSE OF ALL SPILLED LIQUID.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:HANDLE AS A FLAMMABLE LIQ.EXHAUST TO A
FIRE SAFE AREA.
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:
Decomp Temp:Decomp Text:
Vapor Density:4.2
Spec Gravity:1.1 (WATER=1)
Evaporation Rate & Reference:9.1 (ETHER=1)
Solubility in Water:SLIGHT
Appearance and Odor:PAINT WITH A PETROLEUM ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDZING AGENTS.
Hazardous Decomposition Products:CARBON MONOXIDE IF BURNED WITH
INSUFFICIENT AIR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .DO NOT ALLOW TO ENTER SEWERS
WHERE VAPORS MAY BE IGNITED.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:RESPIRATORY PROTECTION REQUIRED IF AIRBORNE
NIOSH/MSHA APPROVED HIGH-EFFICIENCY PARTICULATE RESPIRATOR IS
RECOM. ABOVE THIS LEVEL, A NIOSH/ MSHA APPROVED SCBA IS ADVISED.
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO MEET TLV
REQUIREMENTS.
Other Protective Equipment:UNIFORM AND PROTECTIVE SUIT ARE RECOMMENDED.
EMERGENCY EYEBATH & DELUGE SHOWER .
Work Hygienic Practices:WASH CLOTHING BEFORE RE-USE. WASH THOROUGHLY
AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Preparer's Name:M. HECHT
* Composition/Information on Ingredients *
Ingred Name:PHOSPHORIC ACID (SARA III)
OSHA PEL:1 MG/M3;3 STEL
ACGIH TLV:1 MG/M3;3 STEL
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT WITH SKIN OR EYES MAY CAUSE
SEVERE IRRITATION OR BURNS. INHALATION OF VAPORS MAY CAUSE SEVERE
IRRITATION OF RESPIRATORY SYSTEM.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE IDENTIFIED.
* First Aid Measures *
First Aid:CALL PHYSICIAN. INGESTION: DO NOT INDUCE VOMITING; IF
CONSCIOUS, GIVE WATER, MILK, OR MILK OF MAGNESIA. SKIN:FLUSH WITH
CONTAMINATED CLOTHING AN D SHOES. EYES: FLUSH WITH PLENTY OF WATER
BREATHING (GIVE ARTIFICIAL RESPIRATION/OXYGEN) .
* Fire Fighting Measures *
Extinguishing Media:USE WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL OR
ORDINARY FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:GIVES OFF FLAMMABLE VAPORS. VAPORS MAY
FORM EXPLOSIVE MIXTURE WITH AIR. CLOSED CONTAINERS EXPOSED TO HEAT
MAY EXPLODE.
* Accidental Release Measures *
Spill Release Procedures:WEAR NIOSH/MSHA APPRVD SCBA AND FULL PROT
CLOTHING. STOP LEAK IF YOU CAN DO SO W/OUT RISK. VENT AREA. NEUT
SPILL WITH SODA ASH OR LIME. WITH CLEAN SHOVEL, CAREFULLY PLACE
MATL INTO CLEAN, DRY CNTNR & COVER; REMOVE FROM AREA. FLUSH SPILL
AREA W/H*2O.
Neutralizing Agent:SEE SPILL PROC.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN CORROSION-PROOF AREA.
Other Precautions:DO NOT GET IN EYES, ON SKIN, ON CLOTHING. AVOID
BREATHING VAPOR. KEEP IN TIGHTLY CLOSED CONTAINER. USE WITH
ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.
* Physical/Chemical Properties *
Vapor Pres:2.2
Vapor Density:3.4
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS, ODORLESS, SYRUPY LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
MOST COMMON METALS, STRONG BASES.
Stability Condition to Avoid:
Hazardous Decomposition Products:OXIDES OF PHOSPHOROUS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE, AND LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:SUFFICIENT TO MAINTAIN OPERATOR EXPOSURE <APPLICABLE
OCCUPATIONAL EXPOSURE STANDARDS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
USE OF A HAZARDOUS CHEMICAL MAY REQUIRE SUPPLEMENTAL VENTILATION FOR
PROTECTION OF PERSONNEL & FOR CONTROLLING FIRE/EXPLOSION HAZARD. A
QUALIFIED INDEPENDENT TESTING COMPANY CAN DETERMINE IF EXISTING
CONCENTRATIONS ARE W/IN ESTABLISHED RECOMMENDED/PERMISSIBLE
EXPOSURE LEVELS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:DIETHYLENE GLYCOL BUTYL ETHER ACETATE, ETHANOL, 2-
(2-BUTOXYETHOXY), BUTYL CARBITOL ACETATE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MODERATE IRRITATION. SKIN:
SLIGHT IRRITATION. INHALATION: NASAL & RESPIRATORY IRRITATION, CNS
EFFECTS, DEATH. INGESTION: GI IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DIZZINESS, WEAKNESS, FATIGUE,
NAUSEA, HEADACHE, UNCONSCIOUSNESS, VOMITING, DIARRHEA, REDNESS,
TEARING.
* First Aid Measures *
INHALATION: REMOVE TO FRESH AIR. INGESTION: IF CONSCIOUS GIVE 2
GLASSES OF WATER & INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
* Fire Fighting Measures *
Extinguishing Media:DRY CHEMICAL, CO2, ALCOHOL FOAM.
Fire Fighting Procedures:WEAR A SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:VAPORS ARE >AIR & MAY TRAVEL ALONG GROUND
TO DISTANT IGNITION SOURCE.
* Accidental Release Measures *
Spill Release Procedures:REMOVE IGNITION SOURCES. ABSORB MATERIAL
W/VERMICULITE/FLOOR ABSORBENT. DISPOSE OF CONTAMINATED MATERIALS
*Handling and Storage *
Handling and Storage Precautions:FOR FLAMMABLE/COMBUSTIBLE PRODUCTS,
COMBUSTIBLE LIQUIDS CODE.
Other Precautions:CONTAINERS MAY BE HAZARDOUS WHEN EMPTIED, SINCE
EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES WHICH CAN GENERATE
VAPORS W/IN FLAMMABLE LIMITS.
* Physical/Chemical Properties *
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLUE LIQUID/SEMI-SOLID INK W/MILD ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES/MINERAL ACIDS.
Stability Condition to Avoid:HEAT, FLAME & OTHER IGNITION SOURCES.
Hazardous Decomposition Products:CO & CO2.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. IT'S THE RESPONSIBILITY OF THE GENERATOR OF THE WASTE
TO DETERMINE WHETHER THE WASTE GENERATED MEETS THE FEDERAL/STATE
HAZARDOUS WASTE CRITERIA.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF ENGINEERING CONTROLS ARE INADEQUATE TO
CONTROL VAPOR CONCENTRATIONS TO AN ACCEPTABLE LEVEL, A
NIOSH-APPROVED ORGANIC VAPOR RESPIRATOR SHOULD BE WORN.
Ventilation:ADEQUATE
Other Protective Equipment:SAFETY SHOWER AND EYE WASH FOUNTAIN SHOULD
BE LOCATED NEARBY. SAFETY SHOES, CHEMICAL RESISTANT APRON OR
COVERALL
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
KEY1:P1. THIS PRODUCT IS A KIT CONSISTING OF TWO PARTS. PART A, HAS PNI
A; PART B HAS PNI B, SAME NSN.
* Product Identification *
Kit Part:Y
Preparer's Name:M. WHEELOCK
* Composition/Information on Ingredients *
Ingred Name:METHYL ETHYL KETONE PEROXIDE (MEKP) (CERCLA)
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 0.7 PPM
Fraction by Wt: 0 - 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 PPM
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY &
GI TRACTS. ACUTE- MAY CAUSE SEVERE EYE IRRITATION & DAMGE. SKIN
CONTACT MAY CAUSE IRRITATION & REDNESS. INHALATION OF VAPORS ARE
CORROSIVE TO TO NOSE, THROAT & PULMONARY SYSTEM. INGESTION IS
VERY CORROSIVE. MAY BE HARMFUL OR FATAL. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, SKIN REDNESS, EYE DAMAGE, PAIN,
COUGH, DISCOMFORT
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION MAY BE
MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.
* First Aid Measures *
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:IMMEDIATELY FLUSH WITH
SKIN:WASH WITH SOAP & WATER. ORAL:DO NOT INDUCE VOMITING. SEEK
MEDICAL ATTENTION IMMEDIATELY. IF CONSCIOUS, RINSE MOUTH WITH
WATER. IF SPONTANEOUS VOMITING OCCURS, MONITOR FOR BREATHING
DIFFICULTY.
* Fire Fighting Measures *
Flash Point Method:SCC
Extinguishing Media:WATER SPRAY/FOG, CARBON DIOXIDE, SAND, FOAM/DRY
CHEMICAL. WATER SPRAY MAY BE USED TO KEEP FIRE EXPOSED CONTAINERS
COOL.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. EVACUATE AREA AND FIGHT FIRE
FROM SAFE DISTANCE.
Unusual Fire/Explosion Hazard:PEROXIDES AND DECOMPOSITION PRODUCTS ARE
FLAMMABLE AND CAN IGNITE WITH EXPLOSIVE FORCE IF CONFINED.
* Accidental Release Measures *
Spill Release Procedures:AVOID PERSONAL CONTACT. ABSORB WITH SAND OR
INERT MATERIAL. REMOVE WITH NON-SPARKING TOOLS. PLACE IN DOUBLE
POLYETHYLENE, LABELED BAGS FOR WASTE DISPOSAL. WASH AREA WITH SOAP
AND WATER AFTER PICKUP IS COMPLETE.
Neutralizing Agent:NOT RELEVANT
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL PLACE, AWAY FROM SOURCES
OF IGNITION & INCOMPATIBLE MATERIALS. KEEP OUT OF REACH OF
CHILDREN. KEEP CONTAINER CLOSED. KEEP FROM FREEZING.
Other Precautions:EMPTY CONTAINER MAY RETAIN HAZARDOUS RESIDUES. AVOID
BREATHING VAPORS. DO NOT GET IN EYE, ON SKIN OR ON CLOTHING. DO NOT
STORE NEAR COMBUSTIBLES. WASH THOROUGHLY AFTER HANDLING.
* Physical/Chemical Properties *
HCC:F4
NRC/State Lic Num:NOT RELEVANT
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID, FAINT KETONE ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:NO
STRONG OXIDIZING AGENTS, STRONG ACIDS, STRONG BASES, REDUCING AGENTS,
ACCELERATORS
Stability Condition to Avoid:IGNITION SOURCES, HEAT, CONTAMINATION
Hazardous Decomposition Products:FLAMMABLE AND TOXIC VAPORS
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:ALL-PURPOSE CANISTER MASK AVAILABLE
Ventilation:ADEQUATE TO MAINTAIN VAPOR CONCENTRATION BELOW TLV.
Other Protective Equipment:APPROVED WORKING CLOTHES; EYEBATH
Supplemental Safety and Health
* Product Identification *
Product ID:TOLUOL
* Composition/Information on Ingredients *
Ingred Name:TOLUENE (SARA III)
* Hazards Identification *
Effects of Overexposure:CAUSES EYE IRRITATION. HARMFUL IF INHALED OR
SWALLOWED
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. CALL DOCTOR IF BREATHING IS
DIFFICULT. EYES & SKIN: FLUSH WITH WATER. INGEST: DO NOT INDUCE
VOMITING. IF CONSCIOUS GIVE WARM WATER, THEN MINERAL OIL FOLLOWED
BY HOT COFFEE OR TEA. CALL A PHYSICIAN.
* Fire Fighting Measures *
Lower Limits:1.4
Upper Limits:6.7
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, FOAM
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION &
FLAMMABLES. ABSORB SPILL ON SAND, EARTH, OR VERMICULITE. CAREFULLY
SWEEP UP & REMOVE. ALLOW TO EVAPORATE. FLUSH SPILL AREA WITH WATER.
*Handling and Storage *
Handling and Storage Precautions:PROTECT CONTAINERS AGAINST PHYSICAL
DAMAGE. KEEP AWAY FROM HEAT, SPARKS & FLAME. KEEP IN TIGHTLY CLOSED
CONTAINERS.
Other Precautions:AVOID BREATHING VAPORS. AVOID CONTACT WITH EYES,
SKIN, OR CLOTHING. USE WITH ADEQUATE VENTILATION. AVOID
PROLONGED/REPEATED SKIN CONTACT. WASH THOROUGHLY AFTER HANDLING.
* Physical/Chemical Properties *
HCC:F2
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORLESS LIQUID; BENZENE-LIKE ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS, & FLAME
* Disposal Considerations *
Waste Disposal Methods:ATOMIZE INTO AN INCINERATOR PROVIDING
ENVIRONMENTAL REGULATIONS PERMIT.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:WASH THOROUGHLY BEFORE EATING.REMOVE CLOTHING
AT THE END OF THE WORK DAY AND WASH BEFORE REUSE.
Supplemental Safety and Health
N/K
* Product Identification *
Preparer's Name:TIMOTHY J VUOLO
* Composition/Information on Ingredients *
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
Fraction by Wt: <5.0%
Other REC Limits:
Ingred Name:VM&P NAPHTHA (LIGROINE)
Other REC Limits:
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXTENDED EXPOSURE COULD CAUSE CORNEAL
DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:IRRITATION.EXTENDED EXPOS COULD CAUSE
CORNEAL DAMAGE.SKIN:SHORT EXPOS:NO IRRIT.REPEATED,LONG-TERM EXPOS
MAY CAUSE MILD IRRITATION,POSSIBLE MILD SUPERFICIAL
BURN.INGESTION:MAY CAUSE VOMITING.ASPIR OF VOMITUS INTO LUNGS MAY
RESULT IN CHEM PNEUMONITIS & PULMONARY
EDEMA/HEMORRHAGE.INHALATION:CONSIDERED LOW IN HAZARD.
Medical Cond Aggravated by Exposure:NONE
* First Aid Measures *
MEDICAL ATTENTION.SKIN:WASH WITH SOAP & WATER.IF EXPOSED SKIN
BECOMES PERSISTENTLY IRRITATED,SEEK ADVICE OF MEDICAL
PROFESSIONAL.INGESTION :DO NOT INDUCE VOMITING.KEEP VICTIM
WARM,QUIET & GET MEDICAL ATTENTION IMMED.IF VOMITING OCCURS,KEEP
HEAD BELOW HIPS TO PREVENT ASPIR OF LIQ INTO LUNGS.INHAL:REMOVE
PERSON FROM AREA TO FRESH AIR.
* Fire Fighting Measures *
Extinguishing Media:FOAM,CARBON DIOXIDE,DRY CHEMICAL,WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
.IF FIRE INVOLVES DRIED ADHESIVE,WEAR SCBA W/ FULL FACEPIECE
OPERATED IN PRESS DEMAND OR POSITIVE PRESS MODE.
Unusual Fire/Explosion Hazard:WET ADHESIVE IS NON-FLAM.DRIED ADHESIVE
FILM WILL BURN AS ANY CLASS A FIRE.HAZ DECOMP PROD:CO,CO*2 AND
AROMATIC & ALIPHATIC HYDROCARBONS.COMBUST PROD ARE TOXIC.
* Accidental Release Measures *
Spill Release Procedures:PICK UP SPILLED ADHESIVE AND RETURN IT TO A
NON-LEAKING CONTAINER.WASH RESIDUE WITH WARM SOAPY WATER WHILE
STILL WET.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL,DRY LOCATION.PROTECT
FROM FREEZING.
Other Precautions:NONE
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:
Decomp Temp:Decomp Text:
Vapor Pres:
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:
Appearance and Odor:
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:AVOID EXPOSURE OF THE ADHESIVE TO HIGH
HEAT OR FLAMES.
Hazardous Decomposition Products:CARBON MONOXIDE,CARBON DIOXIDE AND
AROMATIC & ALIPHATIC HYDROCARBONS.THE COMBUSTION PRODUCTS MUST BE
CONSIDERED TOXIC.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .BURY IN AN APPROVED LANDFILL
OR BURN SOLID WASTES IN AN ADEQUATE INCINERATOR.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
BY DGSC-STF.
* Product Identification *
Product ID:1R5
* Composition/Information on Ingredients *
Ingred Name:URANIUM
* Hazards Identification *
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
* First Aid Measures *
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
* Fire Fighting Measures *
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
* Accidental Release Measures *
*Handling and Storage *
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
* Physical/Chemical Properties *
HCC:A3
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-IN ACCORDANCE WITH
DOD REGULAIONS AND FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF ENGINEERING CONTROLS ARE NOT FEASIBLE, THE
Ventilation:LOCAL EXHAUST VENTILATION IS REQUIRED TO MEET THE
PERMISSIBLE EXPOSURE LIMITS (PEL) DURING THE USE OF THIS PRODUCT.
Other Protective Equipment:IMPERVIOUS BOOTS, APRON, PROTECTIVE CLOTHING
AS REQUIRED BY JOB CONDITIONS. EYE WASH STATION, SAFETY SHOWER,
WAHSING FACILITIES NEAR WORK AREA.
Work Hygienic Practices:DO NOT WEAR CONTACT LENSES.
Supplemental Safety and Health
ABBREVIATION: N/A = NOT APPLICABLE. N/AV = NOT AVAILABLE. N/K =
UNKNOWN. N/P = NOT PROVIDED. N/R = NOT RELEVANT. N/D = NOT
DETERMINED. N/E = NOT ESTABLISHED. CNS = CENTRAL NERVOUS SYSTEM. GI
= GASTROI NTESTINAL. SCBA = SELF CONTAINED BREATHING APPARATUS. EMS
= EMERGENCY MEDICAL SERVICE.
* Product Identification *
Preparer's Name:NOT PROVIDED
* Composition/Information on Ingredients *
Ingred Name:NICKEL SULFATE
OSHA PEL:1 MG/M3
ACGIH TLV:0.1 MG/M3
Ingred Name:FORMIC ACID
Minumum % Wt:3.
Maxumum % Wt:7.
OSHA PEL:9 MG/M3;5 PPM
ACGIH TLV:9.4 MG/M3;5 PPM
Ingred Name:WATER
Other REC Limits:NOT PROVIDED
Code:F
Code:F
* Hazards Identification *
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: SKIN, EYES, NASAL
CAVITY, LUNGS, KIDNEYS, LIVER. EYE CONTACT CAUSES IRRITATION, BURNS
POSSIBLE. SKIN CONTACT MAY CAUSE IRRITATION, SKIN SENSITIZATION AND
ALLERGIC REACTION (NICKEL RASH) . INHALATION OF VAPOR OR MIST MAY
BE HARMFUL. HARMFUL IF INGESTED, MAY CAUSE LIVER DAMAGE, KIDNEY AND
GASTROINTESTINAL DAMAGE. CHRONIC: PROLONGED OR REPEATED EXPOSURE
MAY CAUSE DAMAGE TO SKIN, EYES A ND RESPIRATORY SYSTEM AND TEETH.
MAY CAUSE SEVERE AND DELAYED HEALTH EFFECTS SUCH AS INFLAMMED LUNGS
AND CHEMICAL BRONCHITIS. PROLONGED EXPOSURE TO NICKEL AND NICKEL
COMPOUNDS MAY INCREASE THE POSSIBI LITY OF NASAL SINUS AND LUNG
CANCER.
Explanation of Carcinogenicity:CONTAINS NICKEL SULFATE.
Effects of Overexposure:EYES-IRRITATION, BURNS POSSIBLE.
SKIN-IRRITATION, SENSITIZATION, DERMATITIS. INHALED-SNEEZING, NASAL
DISCHARGE, COUGHING, HEADACHES, DIZZINESS, NAUSEA, FATUGUE,
DIFFICULTY BREATHING. INGESTED-IRRITATI ON OF MOUTH, THROAT,
STOMACH; LIVER DAMAGE WITH JAUNDICE, KIDNEY AND GASTROINTESTINAL
DAMAGE.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN AND EYE
CONDITIONS; RESPIRATORY SYSTEM DISORDERS; PREEXISTING SENSITIZATION
TO NICKEL.
* First Aid Measures *
First Aid:EYES: HOLD EYELIDS APART, FLUSH EYES WITH PLENTY OF WATER FOR
SHOES. THOROUGHLY DECONTAMINATE CLOTHING AND SHOES. INHALATION:
REMOVE TO FRESH AIR. LAY VICTIM DOWN, LEGS RAISED. LOOSEN TIGHT
CLOTHING, COVER WITH A BLANKET. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN. INGESTION: DO
NOT INDUCE VOMITING, UNLESS ADVISED BY EMS. GIVE VICTIM LARGE
QUANTITIES OF WATER OR MILK. GIVE MILK OF MAGNESIA OR FRESH EGGS.
NEVER GIVE ANYTHI NG BY MOUTH TO AN UNCONSCIOUS PERSON.
* Fire Fighting Measures *
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:ALL. MATERIAL WILL NOT BURN.
Fire Fighting Procedures:NIOSH/MSHA APPROVED POSITIVE PRESSURE
SELF-CONTAINED BREATHING APPARATUS. STRUCTURAL FIRE FIGHTERS
PROTECTIVE CLOTHING MAY NOT PROVIDE ADEQUATE PROTECTION.
Unusual Fire/Explosion Hazard:CONTAINERS CAN BUILD UP PRESSURE AND
BURST IF EXPOSED TO HEAT(FIRE). CONTACT WITH METALS MAY FORM
FLAMMABLE HYDROGEN GAS. WATER RUNOFF CAN CAUSE ENVIRONMENTAL
DAMAGE. DIKE AREA FOR LATER DISPOSAL.
* Accidental Release Measures *
Spill Release Procedures:DO NOT TOUCH OR WALK THROUGH SPILLED MATERIAL.
ISOLATE HAZARD AREA. ELIMINATE IGNITION SOURCES. PROVIDE MAXIMUM
VENTILATION. DO NOT RELEASE INTO SOIL, SEWERS OR NATURAL BODIES OF
WATER. WEAR PROPER PR OTECTIVE EQUIPMENT. CAREFULLY MOP UP OR
VACUUM SPILL AND TRIPLE RINSE WITH WATER INTO SUITABLE PLASTIC
CONTAINER. RELEASE OF A REPORTABLE QUANTITY (RQ) REQUIRES
NOTIFICATION OF PROPER AUTHORITIES.
Neutralizing Agent:SODA ASH AND CRUSHED LIMESTONE.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED IN
AND PHYSICAL HAZARDS. DO NOT REMOVE OR DEFACE CONTAINER LABELS.
Other Precautions:USE "BUDDY SYSTEM" WHEN WORKING WITH CHEMICALS. DO
NOT GET IN EYES, ON SKIN, ON CLOTHING. DO NOT BREATHE VAPOR, MIST
OR GAS. USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER
HANDLING. TRIPLE RINSE CONTAINER CLEAN BEFORE DISCARDING. PUT
NOTHING ELSE IN THIS CONTAINER.
* Physical/Chemical Properties *
HCC:C2
NRC/State Lic Num:NOT RELEVANT
Decomp Temp:Decomp Text:NOT PROVIDED
Vapor Pres:NOT AVAILABLE
Vapor Density:N/AV
pH:2.2-2.6
Evaporation Rate & Reference:<1 (ETHYL ETHER=1)
Solubility in Water:COMPLETE
Appearance and Odor:DARK GREEN LIQUID, PUNGENT ODOR
Percent Volatiles by Volume:NOT PROVIDED
Corrosion Rate:NOT PROVIDED
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH REACTIVE METALS, STRONG BASES, OXIDIZERS, CYANIDES,
SULFIDES.
Stability Condition to Avoid:STABLE UNDER NORMAL AMBIENT CONDITIONS.
Hazardous Decomposition Products:HYDROGEN (H2), SULFUR OXIDES (SOX),
CARBON OXIDES (COX), NICKEL (NI).
* Toxicological Information*
Toxicological Information:NOT AVAILABLE.
* Ecological Information *
Ecological:NOT AVAILABLE.
* Disposal Considerations *
Waste Disposal Methods:SHIP TO APPROVED TREATMENT/DISPOSAL FACILITY.
DISPOSE OF ACCORDING TO LOCAL, STATE, AND FEDERAL REGULATIONS. EPA
OF EMPTY CONTAINERS AND RINSATE. CONTAMINATION MAY AFFECT DISPOSAL
REQUIREMENTS. THE RESPONSIBILITY FOR PROPER WASTE DI SPOSAL IS WITH
THE GENERATOR OF THE WASTE.
* MSDS Transport Information *
Transport Information:DOT, IATA, ICAO, IMO DESCRIPTION: PROPER
SHIPPING NAME: CORROSIVE LIQUID, ACIDIC, ORGANIC N.O.S. (CONTAINS
PACKAGING GROUP (PG) III LA BEL REQUIREMENTS: 8 - CORROSIVE. UNTI
CONTAINER:1 LITER, 4 LITER POLYETHYLENE BOTTLE. PACKAGING: MEETS
PERFORMANCE ORIENTED PACKAGING REQUIREMENTS. REPORTABLE QUANTITY
* Regulatory Information *
SARA Title III Information:1. THIS PRODUCT CONTAINS A TOXIC CHEMICAL OR
TITLE III OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT
7%. 2. CERCLA AND EPCRA: THRESHOLD PLANNING QUANTITY: NONE.
SUBSTANCE: NONE.3. EPCRA HAZARD CATEGORIES: IMMEDIATE (ACUTE)
HEALTH: YES. DELAYED (CHRONIC) HEALTH: YES. FIRE: NO. SUDDEN
RELEASE OF PRESSURE: NO. REACTIVITY: NO.
Federal Regulatory Information:ALL INGREDIENTS OF THIS PRODUCT ARE
LISTED UNDER THE TOXIC SUBSTANCE CONTROL ACT (TSCA). ODS
CERTIFICATION: THIS PRODUCT DOES NOT CONTAIN AND IS NOT
MANUFACTURED WITH OZONE DEPLETING SUBSTANCES (ODS) . VOC
CERTIFICATION: THIS PRODUCT DOES NOT CONTAIN ANY VOLATILE ORGANIC
COMPOUNDS (VOC). PCB: THIS PRODUCT DOES NOT CONTAIN ANY
POLYCHLORINATED BIPHENYLS (PCB).
PRODUCT CONTAINS DETECTABLE AMOUNTS OF CHEMICALS KNOWN TO THE STATE
OF CALIFORNIA TO CAUSE CANCER, BIRTH DEFECTS OR OTHER REPRODUCTIVE
HARM.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
TYPE OF AIRBORNE CONTAMINANTS AGAINST WHICH THE RESPIRATOR IS
EFFECTIVE & HOW IT IS TO B E PROPERLY FITTED.
Ventilation:GENERAL DILUTION OR LOCAL EXHAUST
Work Hygienic Practices:REMOVE & WASH CONTAMINATED CLOTHES & SHOES
BEFORE REUSE.
Supplemental Safety and Health
IF THIS MATERIAL IS PART OF A MULTIPLE COMPONENT COATING SYSTEM, READ
THE MSDS FOR THE OTHER COMPONENT(S) BEFORE BLENDING AS THE
RESULTING MIXTURE MAY HAVE THE HAZARDS OF ALL OF ITS PARTS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SILICA DIOXIDE, CRYSTALLINE QUARTZ, SAND (SUSPECTED HUMAN
CARCINOGEN BY IARC)
Fraction by Wt: 1-2%
OSHA PEL:SEE TABLE Z3
Fraction by Wt: 1-2%
Fraction by Wt: 1-2%
ACGIH TLV:0.2 MG/CUM
Fraction by Wt: 1-2%
Ingred Name:FILM FORMERS
Ingred Name:RESIN
Ingred Name:ADDITIVES
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INGESTION: HARMFUL OR FATAL. EYES:
IRREVERSIBLE DAMAGE. SKIN: HARMFUL ABSORPTION, CORROSIVE, BURNS,
ALLERGIC REACTION. INHALATION: HARMFUL, EYES, NOSE, THROAT
IRRITATION, RESPIRATORY SYSTEM IRRITATION .
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:INHALATION: NERVOUS SYSTEM DAMAGE, HEADACHES,
NAUSEA, DIZZINESS & LOSS OF COORDINATION, SILICOSIS. EYES:
WATERING, ITCHING, BURNING SENSATION & VISUAL DISTURBANCES. SKIN:
DRYNESS, ITCHING, CRACKING, B URNING, REDNESS & SWELLING.
* First Aid Measures *
First Aid:INGESTION: DON'T INDUCE VOMITING. EYES: FLUSH IMMEDIATELY
INHALATION: REMOVE TO FRESH AIR. APPLY ARTIFICIAL RESPIRATION &
OTHER SUPP ORTIVE MEASURES AS REQUIRED. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:1.0
Extinguishing Media:CO2, DRY CHEMICAL OR UNIVERSAL AQUEOUS FILM FORMING
FOAM DESIGNED TO EXTINGUISH COMBUSTIBLE LIQUID FIRES.
Fire Fighting Procedures:WATER SPRAY MAY BE USED TO COOL CONTAINERS TO
PREVENT PRESSURE BUILD-UP & POSSIBLE AUTOIGNITION WHEN EXPOSED TO
HEAT. IF WATER IS USED/FOG NOZZLES ARE PREFERRED
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. TOXIC GASES MAY FORM WHEN PRODUCT IS
CONTACTED BY HEAT OR FLAME. DON'T APPLY ON HOT SURFACES.
* Accidental Release Measures *
Spill Release Procedures:PROVIDE MAXIMUM VENTILATION. ONLY PERSONNEL
EQUIPPED W/PROPER PROTECTIVE EQUIPMENT SHOULD ENTER THE AREA.
REMOVE ALL SOURCES OF IGNITION. TAKE UP SPILLED MATERIAL W/SAWDUST,
VERMICULITE, OR OTHER ABSO RBENT MATERIAL & PLACE IN CONTAINER
FORDISPOSAL.
*Handling and Storage *
QUANTITIES IN BUILDINGS DESIGNED & PROTECTED FOR STORAGE OF MFPA
CLASS II COMBUSTIBLES LIQUIDS.
Other Precautions:CONTAINERS SHOULD BE GROUNDED WHEN POURING. AVOID
FREE FALL OF LIQUIDS IN EXCESS OF A FEW INCHES. AVOID CONTACT
W/SKIN/EYES & CLOTHES. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING & INHALING THE C ONTENTS CAN BE HARMFUL OR FATAL.
* Physical/Chemical Properties *
Vapor Pres:2.0
Vapor Density:>AIR
Solubility in Water:INSOLUBLE
Appearance and Odor:VISCOUS LIQUID W/AN CHARACTERISTIC ODOR OF
SOLVENTS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, STRONG MINERAL ACIDS OR STRONG OXIDIZINGS AGENTS.
Stability Condition to Avoid:OPEN FLAME, HEAT, SPARKS OR ELECTRICAL
EQUIPMENT.
Hazardous Decomposition Products:WELDING, BRAZING, OR FLAME-CUTTING ON
SURFACES COATED W/THIS PRODUCT MAY PRODUCE FUMES INCLUDING: CO2.
* Disposal Considerations *
Waste Disposal Methods:WASTE MATERIAL MUST BE DISPOSED OF IN ACCORDANCE
W/FEDERAL, STATE & LOCAL REGULATIONS. EMPTY CONTAINERS SHOULD BE
RECYCLED OR DISPOSED OF THROUGH AN APPROVED WASTE MANAGEMENT
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHERE VENTILATION IS INADEQUATE, USE SUITABLE
RESPIRATOR. WEAR NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:PROVIDE GEN DILUTION/LOC EXHST VENT IN VOL & PATTERN TO
KEEP CONC OF INGS BELOW LOWEST SUGGESTED EXPOS LIMITS, (SUPDAT)
Other Protective Equipment:WEAR PROTECTIVE CLOTHING, INCLUDING
IMPERMEABLE APRON CONSTRUCTED OF NITRILE, NEOPRENE, OR LATEX.
Work Hygienic Practices:CLEAN OR DISCARD CONTAMINATED CLOTHING AND
SHOES.
Supplemental Safety and Health
EXTING MEDIA: NFPA CLASS IIIB COMBUST LIQ FIRES. FIRE FIGHT PROC:
AUTOIGNIT OR EXPLO WHEN EXPOS TO EXTREME HEAT. IF WATER USED, FOG
NOZZ ARE PREF. VENT: LEL IN FIRE & EXPLO HAZ DATA BELOW STATED
LIMIT , & TO REMOVE DECOMP PRODS DURING WELDING/FLAME CUTTING. EFTS
OF OVEREXP: QTYS OF TITANIUM DIOXIDE DUST IN (ING 7)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SUPP DATA: LONG-TERM STUDY DEVELOPED LUNG TUMORS. STUDIES
W/HUMANS INVOLVED IN MFR OF PIGMENT INDICATE NO INCR (ING 8)
Ingred Name:ING 7: RISK OF CANCER FROM EXPOS. POTNTL FOR INHAL OF
TITANIUM DIOXIDE DUSTS FROM COATINGS IS VERY LIMITED. SINCE(ING 9)
Ingred Name:ING 8: OVEREXP ARE NOT EXPECTED, THERE IS NOT SIGNIFICANT
Ingred Name:ING 9:ETHER (DEGBE).DEGBE CONSUMED IN DRINKING WATER AT LOW
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
Ingred Name:CLAY (KAOLIN). RECOMMENDED EXPOSURE LIMIT: PEL/TLV 2 MG/M3
RDUST (MFR).
Fraction by Wt: 2-5%
Other REC Limits:SEE INGREDIENT NAME
Ingred Name:ETHANOL, 2-(2-BUTOXYETHOXY)-; (DIETHYLENE GLYCOL MONOBUTYL
ETHER)
Fraction by Wt: 1-2%
Ingred Name:WATER; (TAP WATER)
Ingred Name:WATER; (DEIONIZED WATER)
Ingred Name:FILM FORMERS, RESINS, AND ADDITIVES
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INGEST: HARMFUL/FATAL IF
SWALLOWED. EYE: CAUSES IRRIT. SKIN: MAY CAUSE SLIGHT IRRIT. MAY BE
ABSORB THRU SKIN. INHAL: VAP & SPRAY MIST MAY BE HARMFUL IF
INHALED. VAP GEN AT ELEV TEMPS IRRIT EYES , NOSE & THROAT. CHRONIC:
AVOID LONG TERM & RPTD CONT. PROD CONTAINS TITANIUM DIOXIDE.
ANIMALS INHALING MASS (SUPDAT)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:REDNESS, ITCHING, BURNING SENSATION AND VISUAL
DISTURBANCES MAY INDICATE EXCESSIVE EYE CONTACT. DRYNESS, ITCHING,
CRACKING, BURNING, REDNESS, AND SWELLING ARE CONDITIONS ASSOCIATED
WITH EXCESSIVE SKIN CONTACT.
Medical Cond Aggravated by Exposure:NOT APPLICABLE.
* First Aid Measures *
First Aid:INGEST: DO NOT INDUCE VOMIT. EYE: FLUSH IMMED W/PLENTY OF
FOLLOWED BY WASHING W/SOAP & WATER. INHAL: REMOVE TO FRESH AIR.
APPLY ARTF RESP & OTHER SUPPORTIVE MEASURES AS REQD. OTHER: IF
INGEST, ANY TYPE OF OVEREXP OR SYMPS OF OVEREXP OCCUR DURING OR
FOLLOWING USE OF PROD,CONT POIS CNTRL CNTR,EMER ROOM/PHYS IMMED;
HAVE MSDS INFO AVAIL.
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:USE NFPA CLASS B EXTINGS (CARBON DIOXIDE, DRY CHEM
OR UNIVERSAL AQUEOUS FILM FORMING FOAM) DESIGNED TO EXTING (SUPDAT)
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT
EQUIP.WATER SPRAY MAY BE INEFT. WATER SPRAY MAY BE USED TO COOL
CLSD CNTNRS TO PVNT PRESS BUILD-UP & POSS (SUPDAT)
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE OR BURST
(DUE TO BUILD-UP OF STEAM PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
* Accidental Release Measures *
Spill Release Procedures:PROVIDE MAXIMUM VENT. ONLY PERS EQUIPPED WITH
IN AREA. REMOVE ALL SOURCES OF IGNITION. TAKE UP SPILLED MATL
W/SAWDUST, VERMICULITE, O R OTHER ABSORB MATL & PLACE INTO
CNTNRSFOR DISP.
Neutralizing Agent:NONE LISTED BY MANUFACTURER.
*Handling and Storage *
QUANTITIES IN BUILDINGS DESIGNED AND PROTECTED FOR STORAGE OF NFPA
CLASS IIIB COMBUSTIBLE LIQS. PROT FROM FREEZING.
Other Precautions:IF MATERIAL IS PART OF A MULTIPLE COMPONENT SYSTEM,
READ MATERIAL SAFETY DATA SHEET(S) FOR OTHER COMPONENT OR
COMPONENTS BEFORE BLENDING AS RESULTING MIXTURE MAY HAVE HAZARDS OF
ALL OF ITS PARTS.
* Physical/Chemical Properties *
HCC:N1
Vapor Density:HVR/AIR
Appearance and Odor:VISCOUS LIQUID W/AN ODOR CHARACT TO CHEM FAMILY &
ANY SOLVS LISTED IN ING SEC.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, STRONG MINERAL ACIDS, OR STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE LISTED BY MANUFACTURER.
Hazardous Decomposition Products:MAY PRODUCE HAZ DECOMP PRODS WHEN
HEATED. WELDING, BRAZING, OR FLAME-CUTTING MAY PRODUCE FUMES INCL:
CARBON MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:WASTE MATERIAL MUST BE DISPOSED OF IN ACCORDANCE
WITH FEDERAL, STATE, PROVINCIAL, AND LOCAL ENVIRONMENTAL CONTROL
REGULATIONS. EMPTY CONTAINERS SHOULD BE RECYCLED OR DISPOSED OF
THROUGH AN APPROVED WA STE MANAGEMENT FACILITY.
| 1 | gloves_mandatory |
Control Measures
*
Cage: DUBOI
Proprietary Ind: Y
*
Contractor Summary
*
Cage: DUBOI
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE & CHRONIC:DEFATS SKIN; MAY IRRITATE EYES.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: SENSITIVE SKIN.
First Aid: INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP)
MEDICAL ATTENTION. SKIN:FLUSH W/FRESH WATER, WASH W/SOAP & WA TER. REMOVE
CONTAMINATED CLOTHING & SHOES. INGEST:GIVE MILK OR WATER. INDUCE
VOMITING. GET MEDICAL ATTENTION. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.
*
Handling and Disposal
*
Spill Release Procedures: FLUSH SMALL AMOUNTS TO DRAIN. COLLECT & RETURN
LARGE AMOUNTS TO CONTAINER. PREVENT SPILLS FROM ENTERING OPEN BODIES OF
WATER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISP MUST BE I/A/W FED, STATE & LOC REGS (FP N). PH
ADJUSTMENT; CONTAINS NO PHOSPHATES. WARNING:PVNT COOLING SYS OVERFLOW FROM
ENTERING STORM WATER DRAINS. USE UNTIL <1 INCH REMAINS IN CNTNR. EMPTY CN
TNR:TRIPLE RINSE CNTNR W/WATER, ADD TO (SUPP DATA)
Handling And Storage Precautions: DO NOT PRESSURE CONTAINER TO EMPTY. KEEP
CONTAINER CLOSED. IF FROZEN, THAW & MIX TO MAKE USABLE.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
*
Fire and Explosion Hazard Information
*
Flash Point Text: NONE
Lower Limits: NONE
Upper Limits: NONE
Extinguishing Media: CO*2, FOAM, DRY CHEMICALS.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE.
*
*
Respiratory Protection: NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N). NONE.
Ventilation: MECHANICAL:NORMAL AIR DILUTION.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: WASTE DISP METH:OPERATION. REMOVE OR DEFACE
LABEL BEFORE SELLING CONTAINER OR DISPOSAL.
*
Physical/Chemical Properties
*
Evaporation Rate & Reference: >1 (N-BUTYL ACETATE=1)
Appearance and Odor: CLEAR LIQUID; MILD ODOR.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: INCOMPATIBLE W/CONCENTRATED MINERAL ACIDS.
Hazardous Decomposition Products: CO W/INCOMPLETE COMBUSTION.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Cage: DUBOI
Assigned IND: Y
Company Name: DUBOIS CHEMICALS DIV OF CHEMED CORP
Label Required IND: Y
Status Code: C
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE & CHRONIC:DEFATS SKIN; MAY IRRITATE EYES.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SHOULD BE NEEDED.
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:EYE BATH, WASHING FACILITIES, SAFETY SHOWER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING, DRINKING OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
NONE
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:WATER
Other REC Limits: RECOMMENDED
Ingred Name:SODIUM SULFITE
Other REC Limits: RECOMMENDED
Ingred Name:SODIUM CARBONATE
Fraction by Wt: 1-5%
Other REC Limits: RECOMMENDED
Ingred Name:SODIUM BICARBONATE
Fraction by Wt: <1%
Other REC Limits: RECOMMENDED
Fraction by Wt: <1%
Other REC Limits: RECOMMENDED
OSHA PEL:2 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALE-EXPECTED TO BE A LOW HAZARD FOR
RECOMMENDED HANDLING. EYE-CAUSES IRRITATION. SKIN-CAUSES
IRRITATION. MAY CAUSE ALLERGIC SKIN REACTION. INGESTION-EXPECTED TO
BE A LOW INGESTION HAZARD.
Explanation of Carcinogenicity:NOT CARCINOGENIC.
Effects of Overexposure: SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure: SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHALE-IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYE-IMMEDIATELY FLUSH WITH PLENTY OF
CONTAMINATED CLOTHING & SHOES & WASH WITH SOAP & WATER. GET
EMDICAL ATTENTION. INGEST-DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL
ATTENTION. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSICOUS PERSON.
* Fire Fighting Measures *
Flash Point:
Extinguishing Media:USE AGENT APPROPIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:
* Accidental Release Measures *
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER.
OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT, THEN PALCE
IN A CONTAINER FOR CHEMICAL WASTE. CLEAN SURFACE THOROUGHLY TO
REMOVE RESIDUAL CONTAMINA TION.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED. KEEP AWAY FROM
INCOMPATIBLE SUBSTANCES.
Other Precautions:AVOID CONTACT WITH EYES, SKIN AND CLOTHING. USE WITH
ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.
* Physical/Chemical Properties *
HCC:B3
Vapor Density:0.6
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID, COLORLESS, ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS.
Stability Condition to Avoid: SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:
* Disposal Considerations *
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MUST BE MADE IN
ACCORDANCE WITH APPLICABLE FEDERAL, STATE AND LOCAL REGULATIONS.
FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:SAFETY SHOWER & EYE BATH.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:OMEGA-AMINOCAPRYLIC ACID
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE HARMFUL BY INHALATION,
INGESTION/SKIN ABSORPTION. EYES/SKIN: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
* First Aid Measures *
WASH W/SOAP & COPIOUS AMOUNTS OF WATER. INHALATION: REMOVE TO FRESH
AIR. GIVE CPR/OXYGEN IF NEEDED. INGESTION: WASH OUT MOUTH W/WATER
IF CONSC IOUS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, CO2, DRY CHEMICAL POWDER/APPROPRIATE
FOAM.
Fire Fighting Procedures:WEAR SCBA & PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
* Accidental Release Measures *
FOR WASTE DISPOSAL. AVOID RAISING DUST. VENTILATE AREA & WASH SITE
AFTER MATERIAL PICKUP I S COMPLETE.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL DRY PLACE. KEEP
TIGHTLY CLOSED.
Other Precautions:AVOID PROLONGED/REPEATED EXPOSURE. AVOID CONTACT
W/EYES, SKIN & CLOTHING. AVOID INHALATION.
* Physical/Chemical Properties *
Appearance and Odor:WHITE POWDER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:COMBUSTION: CO, CO2
* Disposal Considerations *
Waste Disposal Methods:DISSOLVE/MIX W/A COMBUSTIBLE SOLVENT & BURN IN A
CHEMICAL INCINERATOR EQUIPPED W/AN AFTERBURNER & SCRUBBER,
IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF ENGINEERING CONTROLS DO NOT MAINTAIN AIRBORNE
CONCENTRATIONS BELOW RECOMMENDED EXPOSURE LIMITS, AN APPROVED
RESPIRATOR MUST BE WORN. RESPIRATOR TYPE: FULL-FACE ORGANIC VAPOR
CARTRIDGE. IF RESPIRATO RS ARE USED, A PROGRAM SHOULD BE INSTITUTED
Ventilation:USE PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER
ENGINEERING CONTROLS TO MAINTAIN AIRBORNE LEVELS BELOW RECOMMENDED
EXPOSURE LIMITS.
APPROPRIATE FOR RISK OF EXPOSURE
Other Protective Equipment:EYE BATH, WASHING FACILITIES, SAFETY SHOWER
Work Hygienic Practices:NOT PROVIDED
Supplemental Safety and Health
ABBREVIATION: N/A=NOT APPLICABLE OR NOT AVAILABLE. N/K=UNKNOWN. N/P=NOT
PROVIDED. N/R=NOT RELEVANT. N/D=NOT DETERMINED. N/E=NOT
ESTABLISHED.
* Product Identification *
Preparer's Name:NOT PROVIDED
* Composition/Information on Ingredients *
Ingred Name:WATER
Other REC Limits:NOT PROVIDED
Code:F
Code:F
Ingred Name:ACETIC ACID
Other REC Limits:NOT PROVIDED
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EFFECTS OF EXPOSURE: INHALATION: VAPOR
EXTREMELY IRRITATING. EYES: CAUSES SEVERE BURNS. VAPOR EXTREMELY
IRRITATING. SKIN: CAUSES SEVERE BURNS. INGESTION: MAY BE FATAL OR
HARMFUL IF SWALLOWED. MAY CAUS E BURNS OF THE GASTROINTESTINAL
TRACT IF SWALLOWED.
Explanation of Carcinogenicity:CARCINOGENICITY CLASSIFICATION
(COMPONENTS PRESENT AT 0.1% OR MORE): - INTERNATIONAL AGENCY FOR
RESEARCH ON CANCER (IARC): NONE - AMERICAN CONFERENCE OF
GOVERNMENTAL INDUSTRIAL HYGIENISTS (ACGIH): NON E - NATIONAL
TOXICOLOGY PROGRAM (NTP): NONE - OCCUPATIONAL SAFETY AND HEALTH
ADMINISTRATION (OSHA): NONE
Effects of Overexposure:INHALATION: VAPOR EXTREMELY IRRITATING. EYES:
CAUSES SEVERE BURNS. VAPOR EXTREMELY IRRITATING. SKIN: CAUSES
SEVERE BURNS. INGESTION: MAY BE FATAL OR HARMFUL IF SWALLOWED. MAY
CAUSE BURNS OF THE GASTRO INTESTINAL TRACT IF SWALLOWED.
Medical Cond Aggravated by Exposure:NOT PROVIDED
* First Aid Measures *
First Aid:INHALATION: MOVE TO FRESH AIR. IF BREATHING IS DIFFICULT,
GIVE OXYGEN. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. GET
MEDICAL ATTENTION IMMEDIATELY. EYES: IMMEDIATELY FLUSH WITH PLENTY
MINUTES WHILE REMOVING CONTAMINATED CLOTHING AND SHOES. GET MEDICAL
ATTENTION IMMEDIATELY. WASH CONTAMINATED CLOTHING BEFORE REUSE.
CLEAN CONTAMINATED SHOES. INGESTION: DO NOT INDUCE VOMITING. GIVE
VICTIM A GLASS OF WATER. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. CALL PHYSICIA N OR POISON CONTROL CENTER
IMMEDIATELY.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER.
OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT MATERIAL,
THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN SURFACE
THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
Neutralizing Agent:SODIUM BICARBONATE
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED.
Other Precautions:DO NOT BREATHE VAPOR AT CONCENTRATIONS GREATER THAN
THE EXPOSURE LIMITS. DO NOT GET IN EYES, ON SKIN, ON CLOTHING. USE
ONLY WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.
* Physical/Chemical Properties *
HCC:C2
NRC/State Lic Num:NOT RELEVANT
Melt/Freeze Pt:M.P/F.P Text:NOT PROVIDED
Decomp Temp:Decomp Text:NOT PROVIDED
Vapor Density:1.0
pH:3.0
Viscosity:NOT PROVIDED
Evaporation Rate & Reference:NOT PROVIDED
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID - SHARP ODOR
Corrosion Rate:NOT PROVIDED
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE WITH COMMON MATERIALS AND CONTAMINANTS WITH WHICH THE MATERIAL MAY
REASONABLY COME INTO CONTACT.
Stability Condition to Avoid:NOT PROVIDED
Hazardous Decomposition Products:NOT PROVIDED
* Toxicological Information*
Toxicological Information:EFFECTS OF EXPOSURE: ACUTE OVEREXPOSURE TO
EXTREMELY HIGH AIRBORNE CONCENTRATIONS OF RESPIRATORY IRRITANTS HAS
BEEN ASSOCIATED WITH DEVELOPMENT OF AN ASTHMA-LIKE REACTIVE AIRWAYS
SYNDROME (RADS) IN SU SCEPTIBLE INDIVIDUALS. EXTREMELY HIGH
AIRBORNE CONCENTRATIONS ARE NOT GENERATED DURING NORMAL CONDITIONS
OF USE BUT MAY OCCUR FOLLOWING A SPILL. THE POTENTIAL TO GENERATE
EXTREMELY HIGH AIRBORNE CONC ENTRATIONS IN A SPILL SITUATION
DEPENDS UPON PHYSICAL FACTORS SUCH AS THE CONCENTRATION OF THE
SOLUTION, THE VOLUME OF THE SPILL, THE SURFACE AREA OF THE SPILL,
THE SIZE OF ROOM WHERE THE SPILL OCCURE D, AND VENTILATION RATE IN
THE ROOM.
* Ecological Information *
Ecological:THE FOLLOWING PROPERTIES ARE ESTIMATED FROM THE COMPONENTS
POTENTIAL BIOACCUMULATION: LOG POW <1 COD (APPROXIMATE
* Disposal Considerations *
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE, OR LOCAL LAWS. FLUSH TO SEWER WITH LARGE
AMOUNTS OF WATER.
* MSDS Transport Information *
Transport Information:FOR TRANSPORTATION INFORMATION REGARDING THIS
PRODUCT CALL THE KODAK WORLDWIDE TRANSPORTATION HAZMAT HOT LINE:
MONDAY THROUGH FRIDAY .
* Regulatory Information *
SARA Title III Information:CHEMICAL(S) SUBJECT TO THE REPORTING
Federal Regulatory Information:NOT PROVIDED
State Regulatory Information:MATERIAL(S) KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER: NONE - MATERIAL(S) KNOWN TO THE STATE
OF CALIFORNIA TO CAUSE ADVERSE REPRODUCTIVE EFFECTS: NONE
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR DUST MASK
Ventilation:MECHANICAL (GENERAL/LOCAL EXHAUST)
Other Protective Equipment:FULL WORK CLOTHING TO PREVENT REPEATED OR
PROLONGED CONTACT.
Work Hygienic Practices:MATERIAL IS STRONGLY ALKALINE. AVOID SKIN-EYE
CONTACT. DO NOT INHALE OR INGEST. WASH AFTE HANDLING.
Supplemental Safety and Health
NO LONGER MANUFACTURED IN DRY POWDER FORM-ONLY MIXED LIQUID-READY
TO USE FORM-IS AVAILABLE.
* Product Identification *
Product ID:REPRODOL P DEVELOPER, PART B
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:SODIUM FORMALDEHYDE BISULFITE
Fraction by Wt: 6.0%
Ingred Name:BORIC ACID
Fraction by Wt: 3.0%
Ingred Name:SODIUM CARBONATE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITANT TO ALL BODY TISSUES.
Effects of Overexposure:SKIN:CAUSES IRRIT ON PROLONGED/REPEATED
CONTACT; INHAL/INGESTION: OVER-EXPOSURE EFFECTS NOT KNOWN
Medical Cond Aggravated by Exposure:ANY PREEXISTING SENSITIVITY OR
ALLERGY.
* First Aid Measures *
First Aid:INHALE:REMOVE TO FRESH AIR, GIVE CPR/O*2 IF
GET MEDICAL ATTENTION FOR EYES, BREATHING DIFFICULTY, OR OTHER
SYMPTOMS OF OVEREXPOSURE.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:EXTINGUISH WITH AGENT SUITABLE FOR SURROUNDING FIRE
CONTR.
Unusual Fire/Explosion Hazard:NONE NOTED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE IGNITION SOURCES. STOP LEAK.
EVACUATE AREA.DO NOT TOUCH SPILLAGE. SM SPILL:ABSORB W. INERT
ABSORBENT. PLACE IN CLOSED CONTAINER. FLUSH AREA W. WATER. LG
SPILL: DIKE AHEAD FOR LATER DISPOSAL. NOTIFY AUTHORITIES.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL CONTACT. KEEP
CONTAINERS TIGHTLY CLOSED
Other Precautions:KEEP MATERIAL DRY.WASH HANDS AFTER HANDLING.
* Physical/Chemical Properties *
HCC:N1
Boiling Pt:B.P. Text:NOT KNOWN
Solubility in Water:COMPLETE
Appearance and Odor:WHITE SOLID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:AVOID MOISTURE CONTACT
Hazardous Decomposition Products:MAY EMIT OXIDES OF SULFUR ON THERMAL
DECOMPOSITION
* Disposal Considerations *
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR AN APPROPRIATE, PROPERLY FITTED
RESPIRATOR(NIOSH/MSHA APPROVED)DURING & AFTER APPLICATION UNLESS
AIR MONITORING DEMONSTRATES VAPOR/MIST LEVELS ARE BELOW APPLICABLE
LIMITS.
Ventilation:LOCAL EXHAUST RECOMMENDED TO CONTROL EXPOSURE TO
MIST/AEROSOLS. GENERAL EXHAUST: NORMALLY ADEQUATE TO MINIMIZE
EXPOSURE.
Other Protective Equipment:IMPERMEABLE APRONS & BOOTS. SAFETY SHOWER &
EYE BATH.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS BEFORE EATING/USING TOBACCO PRODUCTS/THE
WASHROOM.
Supplemental Safety and Health
TOBACCO & FOOD SHOULD BE CONSUMED IN DESIGNATED AREAS ONLY. FIRE HZRD:
DURING EMERGENCY CONDITIONS, OVEREXPOSURE MAY CONSTITUTE A HLTH
HZRD. SYMPTOMS MAY NOT BE IMMEDIATELY APPARENT. HLTH HZRD: LEAD C
HROMATE: MAY CAUSE LUNG CANCER.
* Product Identification *
CAGE:SERIC
CAGE:SERIC
CAGE:SSERI
* Composition/Information on Ingredients *
Ingred Name:ACETIC ACID, C6-8-BRANCHED ALKYL ESTERS, C3-8-BRANCHED
ALKYL ESTERS ACETIC ACID
Ingred Name:CYCLOHEXANONE, KETOHEXAMETHYLENE
Ingred Name:DIBASIC ESTER
Ingred Name:PIGMENTS
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION/INGESTION: CAN RESULT IN
LEAD POISONING/ENCEPHALOPATHY/DEATH. LEAD COLIC: OVEREXPOSURE CAN
CAUSE DAMAGE TO THE CNS/BRAIN(ENCEPHALOPATHY)/KIDNEY
DISEASE/REPRODUCTIVE TOXICITY IN BOTH MEN & W OMEN/BLOOD FORMING
SYSTEM DISORDERS. OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE. (SUPP)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SEIZURES, COMA, CARDIORESPIRATORY ARREST, LOSS
OF APPETITE, METALLIC TASTE IN MOUTH, ANXIETY, CONSTIPATION,
NAUSEA, PALLOR, EXCESSIVE TIREDNESS, WEAKNESS, INSOMNIA, HEADACHE,
NERVOUS IRRITABILITY, MUS CLE & JOINT PAIN/SORENESS, FINE TREMORS,
NUMBNESS, DIZZINESS, HYPERACTIVITY, COLIC, ABDOMINAL PAIN, ANEMIA.
Medical Cond Aggravated by Exposure:PRE-EXISTING LUNG DISORDERS,
ASTHMA-LIKE CONDITIONS, SENSITIZATIONS/ALLERGIES.
* First Aid Measures *
First Aid:INGESTION: DRINK 2 GLASSES OF WATER TO DILUTE. DON'T INDUCE
VOMITING. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
TREAT SYMPTOMATICALLY. SKIN: WASH W/MILD SOAP & WARM WATER.
INHALATION: REM OVE TO FRESH AIR. GIVE OXYGEN/CPR AS REQUIRED.
TREAT SYMPTOMATICALLY. EYES: FLUSH W/COPIOUS AMOUNTS OF WATER FOR
ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIPMENT. WATER MAY BE
UNSUITABLE FOR BURNING LIQUIDS. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE. USE WATER TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:COMBUSTIBLE LIQUID. CLOSED CONTAINERS MAY
RUPTURE/EXPLODE WHEN EXPOSED TO EXTREME HEAT. APPLICATION TO HOT
SURFACES REQUIRES SPECIAL PRECAUTIONS. (SEE SUPP)
* Accidental Release Measures *
Spill Release Procedures:USING NON-SPARKING TOOLS, PLACE LEAKING
CONTAINERS IN A WELL VENTILATED AREA. AVOID BREATHING VAPORS.
ELIMINATE SOURCES OF HEAT, SPARKS/IGNITION. NOTIFY PROPER
AUTHORITIES IF PUBLIC WATERS/SEWERS ARE CONTAMINATED.
*Handling and Storage *
Handling and Storage Precautions:AVOID PROLONGED STORAGE AT TEMPS IN
Other Precautions:DON'T BREATHE VAPORS/SPRAY MISTS. INTENTIONAL MISUSE
BY DELIBERATELY CONCENTRATING & INHALING THE CONTENTS MAY BE
HARMFUL/FATAL. LEAD CHROMATE: SANDING/BLASTING/ABRADING OF THE
DRIED COATING CAN GENER ATE HARMFUL DUST/PARTICLES IF INHALED.
* Physical/Chemical Properties *
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, OXIDIZERS, ALKALI METAL HYDROXIDES.
Stability Condition to Avoid:EXTREME TEMPS, SPARKS, OPEN FLAMES/OTHER
SOURCES OF IGNITION.
Hazardous Decomposition Products:CO, CO2, MIXED OXIDES OF NITROGEN,
METHYL METHACRYLATE, N-BUTYL METHACRYLATE/HYDROGEN CHLORIDE.
* Disposal Considerations *
Waste Disposal Methods:AS A HAZARDOUS WASTE, MATERIAL MUST BE DISPOSED
OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:PROTECTIVE CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPILL PROC: IS FULLY CURED. HAZ DECOMP: CHLORIDES, FLUORIDES &
PHOSGENE.
* Product Identification *
Product ID:INSTA-STIK
Preparer's Name:A. GIRARD
* Composition/Information on Ingredients *
Ingred Name:POLYETHER POLYOL BLEND.
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:METHANE,CHLORODIFLUORO-; (CHLORODIFLUOROMETHANE)
Ozone Depleting Chemical:2
Ingred Name:ISOCYANIC ACID, METHYLENEDI-P-PHENYLENE
ESTER;(4,4-DIPHENYLMETHANE-DIISOCYANTE (MDI))
Other REC Limits:YN/KNONE RECOMMENDED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:POLYMETHYLENEPOLYPHENYL ISOCYANATE; (HIGHER OLIGOMERS OF
MDI); (POLYMERIC MDI)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PETROLEUM MINERAL OIL;(PETROLEUM DISTILLATES)
OSHA PEL:N/K
ACGIH TLV:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN/INHAL: IRRIT TO EYES, SKIN &
RESP TRACT. MAY CAUSE SENSIT BY SKIN CONT & INHAL.
CHLOROFLUOROCARBON MATLS HAVE PRODUCED SENSIT OF THE MYOCARDIUM TO
EPINEPHRINE IN LAB ANIMALS & COULD HAVE A S IMILAR EFT IN HUMANS.
ADRENOMIMETICS (E.G.,EPINEPHRINE) MAY BE CONTRAINDICATED EXCEPT FOR
LIFE- (SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: SUSTAINING USES IN HUMANS ACUTELY OR
CHRONICALLY EXPOSED TO CHLOROFLUOROCARBONS. SYMPTOMS MAY INCLUDE:
COUGHING, WHEEZING AND SHORTNESS OF BREATH.
Medical Cond Aggravated by Exposure:EXPOSURE TO INDIVIDUALS WITH
ASTHMA, ECZEMA AND OR ALLERGIES MAY AGGREVATE EXISTING CONDITIONS.
* First Aid Measures *
MINUTES WHILE HOLDING EYELIDS OPEN. SKIN: REMOVE CONTAMINATED
CLOTHING; WASH SKIN WITH SOAP WATER. INHAL: REMOVE TO FRESH AIR.
INGEST: IN CASE O F EXCESSIVE INGESTION, GIVE LARGE AMOUNT OF
LIQUIDS. DO NOT INDUCE VOMITING. IN ALL CASES, SEEK ADDITIONAL
MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA &
FULL PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE FLUORIDES, CHLORIDES & PHOSGENE.
* Accidental Release Measures *
Spill Release Procedures:PROVIDE ADEQ VENT. WEAR NIOSH/MSHA APPRVD PROT
CLTHG & EQUIP. SCRAPE UP BULK OF SPILL & PUT IN SUITABLE WASTE
RECEPTACLE. AVOID SPREADING SPILL TO OTHER SURFS. LOOSELY COVER
WASTE CNTNR & PUT IN SAFE PLACE. DISP OF ENTIRE CNTNR AFTER
ADHES(SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:CAUTION! CONTENTS UNDER PRESSURE.
PUNCTURE OR INCINERATE.
Other Precautions:NO SMOKING IN AREA OF USE. DO NOT USE IN THE GENERAL
VICINITY OF ARC WELDING, OPEN FLAMES OR HOT SURFACES. HEAT AND/OR
UV RADIATION MAY CAUSE THE FORMATION OF CHLORIDES,FLUORIDES OR
PHOSGENE
* Physical/Chemical Properties *
Spec Gravity:1.3
Appearance and Odor:OFF WHITE, STICKY MATERIAL WITH A MILD ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
REACTS WITH WATER. AVOID ALKALIES, ACIDS, ALCOHOL AND AMMONIA.
Stability Condition to Avoid:REACTION MAY BE VIOLENT AT ELEVATED
TEMPERATURES.
Hazardous Decomposition Products:CARBON MONOXIDE,CARBON
DIOXIDE,NITROGEN OXIDES,AMMONIA,TRACE AMTS OF HYDROGEN CYANIDE ARE
GIVEN OFF.(SUPP DATA)
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF AIRBORNE CONCENTRATIONS EXCEED PEL, WEAR
NIOSH APPROVED RESPIRATORY PROTECTION IN ACCORDANCE WITH OSHA
Ventilation:MECHANICAL: MUST BE PROVIDED IF NECESSARY TO KEEP EXPOSURE
LEVELS BELOW LISTED TLV AND/OR PEL.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP: INGEST OF COMPLETE PRIMER CAN CAUSE IRRIT TO DIGESTIVE
SYS, & POSS OTHER UNKNOWN EFTS. IF LEFT UNTREATED, WEAK, VOMIT,
LOSS OF APPETITE, UNCOORDINATED BODY MOVEMENTS, CONVLS, STUPOR &
POSS COMA. DMG TO BOTH MALE & FEMALE REPRO SYS IS POSS. (ING 8)
* Product Identification *
CAGE:BLOUN
CAGE:BLOUN
* Composition/Information on Ingredients *
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:1-TETRAZENE, 1-GUANYL-4-NITROSAMINOGUANYL-; (TETRACENE) %:
OSHA PEL:N/K
ACGIH TLV:N/K
OSHA PEL:5 MG BA/M3
ACGIH TLV:2 MG BA/M3
OSHA PEL:N/K
ACGIH TLV:N/K
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2 MG/M3 FUME
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PENTAERYTHRITOL TETRANITRATE; (PETN)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUP DAT: CHRONIC: IF LEFT UNTREATED, WEAK, INSOMNIA,
HYPERTENSION, SLIGHT IRRIT TO SKIN & EYES, METALLIC TASTE (ING 9)
Ingred Name:ING 8: IN MOUTH, ANEMIA, CONSTIP, HDCH, MUSCLE & JOINT
Ingred Name:ING 9: ENCEPHALOPATHY, & DMG TO REPRO SYS IN BOTH MALES &
INFORMATION .
Ingred Name:FIRST AID PROC: PRESENT UNLESS PROD IS FIRED/OTHERWISE
Ingred Name:WASTE DISP METH: ALL STEPS OF THE ABOVE PROCESS SHOULD BE
IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL CODES.
Ingred Name:OTHER PROT EQUIP: TIME-WEIGHTED AVERAGE, USE HEARING
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: AFTER PRIMERS HAVE BEEN
FIRED, DUST, VAP &/FUMES MAY BE IRRIT TO RESP SYS & CAN RSLT IN
BOTH ACUTE & CHRONIC OVEREXP. SKIN CONT: AFTER PRIMERS HAVE BEEN
FIRED, DUST, VAP &/FUMES MAY CAUS E IRRIT. FRAGMENTED PROJECTILES
FROM PRIMERS CAN CAUSE PUNCTURE WOUNDS. SKIN ABSORPTION: AFTER
PRIMERS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: HAVE BEEN FIRED, DUST, VAP &/FUMES
ARE NOT READILY ABSORBED THRU SKIN. EYES: AFTER PRIMERS HAVE BEEN
FIRED, DUST, VAP &/FUMES MAY CAUSE IRRIT. INGEST: WHEN PRIMERS ARE
FIRED/OTHERWISE DISCHA RGED, DUST, VAP &/FUMES MAY BE ABSORBEDBY
DIGESTIVE SYS, & CAN RSLT IN BOTH ACUTE & CHRONIC OVEREXP. (SUP
DAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
MED ATTN. IF PHYSICAL INJURY HAS OCCURRED BECAUSE OF PROJECTILES,
GET IMMED MED ATTN. SKIN: WASH THORO W/SOAP & WATER. IF PHYSICAL
INJURY H AS OCCURRED BECAUSE OF PROJECTILES, GETIMMED MED ATTN.
INHAL: REMOVE FROM EXPOS. GET MED ATTN IF EXPERIENCING EFTS OF
OVEREXP. INGEST: GET IMMED MED ATTN. ALL HAZARDS ARE NOT EXPECTED
* Fire Fighting Measures *
Extinguishing Media:WATER. FOG-TYPE SPRAY TO COOL SURROUNDING
ATMOSPHERE AND COMBUSTIBLES AND TO LOWER TEMPERATURE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:FLAMMABLE AND EXPLOSIVE MATERIAL. PRODUCT
* Accidental Release Measures *
Spill Release Procedures:SCRAP PRIMERS SHOULD BE STORED IN A CONTAINER
OF WATER TO WHICH DETERGENT HAS BEEN ADDED AS A "WETTING" AGENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. DO NOT
CRUSH, DROP, OR PUNCTURE CONTAINER. AVOID HEAT, ELECTRICAL CURRENT,
ACIDS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:THE ONLY PROPER METH FOR PREPARING PRIMERS FOR
RECLAMATION IS TO SUBJECT PRIMERS (IN SML QTYS) TO SUFFICIENT HEAT
TO RENDER PRIMING MIX INERT. AFTER PRIMERS HAVE BEEN RENDERED INERT
BY METH DESCRIBED,REMAINING SCRAP SHOULD BE RECYCLED/DISP. (ING
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:COBALT (SARA III)
OSHA PEL:0.1 MG/M3;AS CO
* Accidental Release Measures *
* Physical/Chemical Properties *
HCC:A3
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SHOULD BE NEEDED
Ventilation:MECHANICAL(GENERAL) RECOMMENDED,LOCAL EXHAUST IF NEEDED
Other Protective Equipment:NONE STATED.BUT GOOD INDUSTRL HYGEIN
PRACTICE SHOULD BE FOLLOWED.
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:AMMONIUM (ETHYLENEDINITRILO) TETRAACETO-FERRATE (III)
Ingred Name:AMMONIA (SARA III)
Fraction by Wt: 6.0%
Other REC Limits:NONE SPECIFIED
Ingred Name:WATER
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CAUSES SKIN AND EYE IRRITATION.
Effects of Overexposure:PER MFR,PRODUCT IS OF LOW HAZARD.HOWEVER,
SOLUTION MAY IRRITATE EYES & MAY CAUSE SKIN ALLERGIC REACTION ON
REPEATED OR PROLONGED SKIN EXPOSURE.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR, GIVE CPR/O*2 IF NEED;
RINSE MOUTH. GET MEDICAL ATTENTION FOR EYES, BREATHING DIFFICULTY,
OR OTHER SY MPTOMS OF OVEREXPOSURE.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:EXTINGUISH WITH AGENT SUITABLE FOR SURROUNDING FIRE
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHINGG TO PREVENT CONTACT W/SKIN & EYES.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE IGNITION SOURCES. STOP LEAK.
EVACUATE AREA.DO NOT TOUCH SPILLAGE.SMALL SPILL: ABSORB WITH INERT
ABSORBENT. PLACE IN CLOSED CONTAINER. FLUSH AREA WITH WATER. LARGE
SPILL: DIKE AHEAD FOR LATER DISPOSAL. NOTIFY AUTHORITIES.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL CONTACT. KEEP
CONTAINERS TIGHTLY CLOSED
Other Precautions:AVOID SKIN,EYES & CLOTHG CONTACT;AVOID CONTACT
* Physical/Chemical Properties *
HCC:N1
Vapor Density:0.6
pH:7.0
Solubility in Water:COMPLETE
Appearance and Odor:OPAQUE,REDDISH-BROWN SOLUTION;SLIGHT AMMONIACAL
ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
PER MFR, METALS
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:MAY EMIT AMMONIA AND OXIDES OF CARBON
& NITROGEN ON COMBUSTION.
* Disposal Considerations *
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR NIOSH APPROVED RESPIRATOR.
Ventilation:USE IN A CHEMICAL FUME HOOD.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER . LAB
COAT. WEAR CHEMICAL RESISTANT CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO: OF NICKEL IN 2% NITRIC ACID. EXPLO HAZ:
* Product Identification *
Preparer's Name:SUSHA RAMONE
* Composition/Information on Ingredients *
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SYMPS & HLTH HAZS FOR DILUTE NITRIC
ACID ARE EXPECTED TO BE LESS SEVERE THAN EXPOS TO CONCENTRATED
PPM) OR GREATER, HLTH HAZS FOR CO NCENTRATED NITRIC ACID ARE GIVEN.
THIS SOLN MAY BE HARMFUL IF INHALED, INGESTED OR CONTACTED W/SKIN
OR (EFTS OF OVEREXP)
CARCIN.
Effects of Overexposure:HLTH HAZ: EYES. NICKEL SALTS ARE CONSIDERED
CARCIN ACCORDING TO OSHA, NTP & IARC. NICKEL SALTS AS DUST/FUME
CAUSE SENTIZ DERM & PROBABLY PRDCE CANCER OF PARANSAL SINUSES &
LUNG. IN HIGH CONCS IT IS RE SP IRRITANT. "NICKEL ITCH" IS DERM
RSLTG FROM SENSIT TO NICKEL. FIRST SYMP IS ITCHING WHICH OCCURS UP
TO 7 DAYS (ING 6)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
LIFTING UPPER & LOWER EYELIDS. SKIN: REMOVE CONTAMINATED CLOTHING,
THOROUGHLY BEFORE REUSE. INHAL: MOVE TO FRESH AIR. INGEST: DO NOT
INDUCE VOMITING. GET IMMED MED HELP. IF PATIENT IS CONSCIOUS, GIVE
LARGE QUANTITIES OF WATER OR MILK. IF IRRITATION CONTINUES, GET MED
ATTN IMMED.
* Fire Fighting Measures *
Extinguishing Media:APPROPRIATE TO SURROUNDING FIRE CONDITIONS.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CONCENTRATED HNO*3 IS NOT COMBUST BUT IS
STRONG OXIDIZER & ITS HEAT OR RXN W/REDUCING AGENTS/COMBUSTS MAY
CAUSE IGNIT. CAN REACT W/METALS TO RELS FLAM (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:VENT AREA. DILUTE SPILL W/WATER & NEUT W/SODA
ASH, LIMESTONE, ETC. WIPE UP & PUT INTO SEALED CNTNR FOR PROPER
DISP. WASH SPILL SITE OFF W/WATER AFTER MATL PICK UP IS COMPLETE.
Neutralizing Agent:SODA ASH, LIMESTONE, ETC.
*Handling and Storage *
Handling and Storage Precautions:CONCENTRATED NITRIC ACID WILL ATTACK
SOME FORMS OF PASTICS, RUBBER AND COATINGS. STORE AT ROOM
TEMPERATURE. KEEP TIGHTLY SEALED WHEN NOT IN USE.
Other Precautions:WARNING: IRRITANT. CORROSIVE. CARCINOGEN. HAVE
IMMEDIATE AVAILABILITY OF AN EYE WASH IN CASE OF EMERGENCY. AVOID
INHALATION, INGESTION AND CONTACT W/EYES AND SKIN. WASH CAREFULLY
AFTER USE.
HYDROGEN GAS. CONCENTRATED HNO*3 REACTS EXPLOSIVELY W/COMBUST
ORGANIC OR READILY OXIDIZABLE MATLS SUCH AS ALCOHOL, WOOD,
TURPENTINE, M ETAL POWDERS, HYDROGEN SULFIDE, ETC.
* Physical/Chemical Properties *
Spec Gravity:APPROX 1
Solubility in Water:SOLUBLE
Appearance and Odor:TRANSPARENT WITH AN ACRID ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CONCENTRATED HNO*3 IS POWERFUL OXIDIZING AGENT. IT REACTS EXPLO
W/COMBUST ORGANIC OR READILY OXIDIZABLE MATLS (ING 4)
Stability Condition to Avoid:STABLE UNDER NORM STORAGE & USE. ELEVATED
TEMPS MAY CAUSE CNTNRS TO BURST & LIBERATE TOXIC OXIDES OF
NITROGEN.
Hazardous Decomposition Products:WILL RELEASE TOXIC NITROGEN OXIDE
FUMES AND VAPORS.
* Disposal Considerations *
Waste Disposal Methods:CONTACT LOCAL HAZARDOUS OR CHEMICAL WASTE
DISPOSAL AGENCY FOR FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:A NIOSH APPROVED RESPIRATOR APPROPRIATE FOR THE
EXPOSURE OF CONCERN . EXPOSURE LIMITS 8HRS TWA (PPM): OSHA
Ventilation:THE USE OF MECHANICAL DILUTION VENTILATION IS RECOMMENDED
WHENEVER THIS PRODUCT IS USED IN A CONFINED SPACE, HEATED ABOVE
AMBIENT TEMPERATURES, OR IS AGITATED.
EXPOSURE IS EXPECTED.
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA .
Supplemental Safety and Health
PRODUCT NAME: PF. PRODUCT DESCRIPTION: DEGREASER SOLVENT. CHEMICAL
FAMILY: VOLATILE, NON-HALOGENATED HYDROCARBON. INGREDIENT
INFORMATION (CONT): HAZARDOUS INGREDIENTS: NONE. NON-HAZARDOUS IN
* Product Identification *
Product ID:PF SOVENT / DEGREASER
CAGE:0JVH6
CAGE:0JVH6
* Composition/Information on Ingredients *
Ingred Name:CITRUS TERENES. (FOOD GRADE D'LIMONENE, HIGHLY REFINED,
LESS THAN 1.0% CYCLOPARAFFINS).
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT: MAY CAUSE IRRITATION,
TEARING AND REDNESS. DOES NOT INJURE EYE. SKIN CONTACT: PROLONGED
OR REPEATED CONTACT WITH SKIN MAY CAUSE DEFATTING OR DRYNESS OF
SKIN. CONTINUED DRYNESS MAY CAUSE DERMATITIS. INHALATION:
EXCESSIVE INHALATION OF VAPORS CAN CAUSE IRRITATION OF THE
RESPIRATORY TRACT, NAUSEA, DIZZINESS OR HEADACHE. INGESTION:
PRODUCT HAS LOW ORDER OF ACUTE ORAL TOXICITY, BUT INGE STION OF
LARGE QUANTITIES MAY CAUSE NAUSEA, VOMITING, AND GASTROINTESTINAL
IRRITATION. MAY CAUSE INJURY IF ASPIRATED INTO LUNGS.
* First Aid Measures *
PERSISTS, CONTACT PHYSICIAN. SKIN CONTACT: WASH THOROUGHLY WITH
SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. INHALATION: IF
AFFECTED BY V APORS, GET TO FRESH AIR. IF BREATHING IS DIFFICULT,
SEE PHYSICIAN. INGESTION: DO NOT INDUCE VOMITING. PRODUCT CONTAINS
HYDROCARBON. CONSULT PHYSICIAN.
* Fire Fighting Measures *
Flash Point Method:TCC
Autoignition Temp Text:APPROX
Lower Limits:1.3% EST.
Upper Limits:8.9% EST.
Extinguishing Media:EXTINGUISH WITH CO2, FOAM OR DRY CHEMICAL.
Fire Fighting Procedures:CLASS B FIRE PROCEDURES. FIREFIGHTERS SHOULD
WEAR NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:GENERAL HAZARDS: COMBUSTIBLE LIQUID. CAN
FORM COMBUSTIBLE MIXTURES AT OR ABOVE FLASH POINT. HAZARDOUS
COMBUSTION PRODUCTS: CARBON DIOXIDE, CARBON MONOXIDE AND SMOKE.
* Accidental Release Measures *
Spill Release Procedures:LAND SPILL: REMOVE IGNITION SOURCES. CONTAIN
THE SPILL. RECOVER FREE PRODUCT. ABSORB WITH SUITABLE CHEMICAL
ABSORBENT FOR DISPOSAL VIA INCINERATION OR BURIAL IN APPROVED
LANDFILL. OBSERVE LOCAL, STATE , AND FEDERAL REGULATIONS. WATER
SPILL: REMOVE FROM WATER BY SKIMMING OR USE OF SUITABLE ABSORBENT.
*Handling and Storage *
Handling and Storage Precautions:ELECTROSTATIC ACCUMULATION HAZARD:
UNKNOWN, USE PROPER GROUNDING PROCEDURES. STORAGE TEMPERATURE:
AMBIENT. GENERAL: KEEP AWAY FROM HEAT SOURCES, OPEN FLAMES AND
OTHER IGNITION SOURCES. KEEP PRODUCT CONTAINERS CLOSED WHEN NOT IN
USE.
* Physical/Chemical Properties *
Vapor Density:> 1, AIR=1
Solubility in Water:NON-MISCIBLE.
Appearance and Odor:COLORLESS LIQUID WITH CHARACTERISTIC ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:HAZARDOUS COMBUSTION PRODUCTS: CARBON
DIOXIDE, CARBON MONOXIDE AND SMOKE.
* Toxicological Information*
Toxicological Information:PLEASE REFER TO (HEALTH HAZARDS) SECTION FOR
AVAILABLE INFORMATION ON POTENTIAL HEALTH EFFECTS.
* Ecological Information *
Ecological:NO SPECIFIC ECOLOGICAL DATA IS AVAILABLE AT THE TIME. SEE
(SPILL RELEASE PROCEDURES) SECTION FOR INFORMATION REGARDING
ACCIDENTAL RELEASES AND (SARA III, FEDERAL REGULATORY AND STATE
REGULATORY) SECT ION(S) FOR REGULATORY REPORTING INFORMATION.
* Disposal Considerations *
Waste Disposal Methods:PLEASE REFER TO (FIRE & EXPLOSION), (SPILL
RELEASE PROCEDURES) AND (SARA III, FEDERAL REGULATORY AND STATE
REGULATORY) SECTION(S) FOR DISPOSAL AND REGULATORY REPORTING
INFORMATION. DISPOSE IN ACCORDAN CE WITH APPLICABLE FEDERAL, STATE,
AND LOCAL REGULATIONS .
* MSDS Transport Information *
Transport Information:DEPARTMENT OF TRANSPORTATION (DOT): DOT PROPER
SHIPPING NAME: NOT APPLICABLE. DOT HAZARD CLASS: NOT HAZARDOUS.
GALLONS CAPACITY OR LESS, THIS PRODUCT IS NOT REGULATED BY DOT.
* Regulatory Information *
NONE.
Federal Regulatory Information:THIS PRODUCT IS DEFINED AS OSHA HAZARD
HAZARD CLASS: NOT HAZARDOUS. TSCA: THE INGREDIENTS IN THIS
PRODUCT ARE LISTED ON THE TSCA INVENTO RY. CERCLA: NOT
REPORTABLE. WE RECOMMEND YOU CONTACT LOCAL AUTHORITIES TO DETERMINE
IF THERE MAY BE OTHER LOCAL REPORTING REQUIREMENTS.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:PROPERLY FITTED NIOSH APPROVED ORGANIC
VAPOR/PARTICULATE RESPIRATOR.
Ventilation:LOCAL EXHAUST:PREFERABLE.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:FLOOR ENAMEL. EXPLAN OF CARCIN:IARC
* Product Identification *
CAGE:ACEHA
CAGE:ACEHA
* Composition/Information on Ingredients *
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
Fraction by Wt: 7.9%
Ingred Name:IRON (III) OXIDE; (RED IRON OXIDE)
Fraction by Wt: 8.8%
ACGIH TLV:5 MG/M3 FUME (FE)
Ingred Name:SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC; (MINERAL
SPIRITS)
Ingred Name:ETHYL ALCOHOL; (ETHANOL)
Fraction by Wt: 0.4%
Ingred Name:ETHANOL, 2-PROPOXY-; (2-PROPOXYETHANOL)
Fraction by Wt: 0.5%
Ingred Name:BROWN IRON OXIDE
Fraction by Wt: 6.8%
OSHA PEL:N/K
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:SILICA GEL; (AMORPHOUS SILICA)
Fraction by Wt: 0.3%
OSHA PEL:6 MG/M3
Ingred Name:CHROMIUM (III) OXIDE (2:3); (CHROMIUM OXIDE)
Fraction by Wt: 6.3%
OSHA PEL:0.5 MG/M3 (MFR)
ACGIH TLV:0.5 MG/M3 (CR)
Ingred Name:ETHANOL, 2-PROPOXY-; (ETHYLENE GLYCOL MONOPROPYL ETHER)
Fraction by Wt: 0.9%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ZIRCONIUM 2-ETHYLHEXANOATE
Fraction by Wt: 0.3%
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (CRYSTALLINE SILICA)
Fraction by Wt: 0.3%
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:ALUMINUM HYDROXIDE
Fraction by Wt: 0.3%
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATION OF EYES, SKIN AND
RESPIRATORY SYSTEM MAY OCCUR ON OVEREXPOSURE. MAY ALSO CAUSE
NERVOUS SYSTEM DEPRESSION. HEADACHE, DIZZINESS, NAUSEA AND LOSS OF
COORDINATION ARE INDICATIONS OF EXCES SIVE EXPOSURE TO VAPORS OR
SPRAY MISTS.CHRONIC:REPORTS HAVE ASSOCIATED REPEATED AND PROLONGED
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:CHROMIUM (III) OXIDE (2:3):NTP 7TH
CRYSTALLINE-QUARTZ: (SUPDAT)
Effects of Overexposure:HLTH HAZ:OCCUPATIONAL OVEREXPOSURE TO SOLVENTS
W/PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING AND INHALING CONTENTS CAN BE HARMFUL OR
FATAL.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
* First Aid Measures *
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE FROM EXPOSURE.
RESTORE BREATHING. KEEP WARM & QUIET. SKIN:WASH AFFECTED AREA
THOROUGHLY W/SOAP & WATER. EYES:FLUSH W/LARGE AMOUNTS OF WATER FOR
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:0.9%
Extinguishing Media:FOR DRY SOLIDS, USE WATER, FOAM, CO*2, DRY
CHEMICALS.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER MAY BE USED TO COOL CLSD CNTNRS TO PVNT PRESS BUILD-UP & POSS
AUTO IGNIT/EXPLO WHEN EXPOS TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPARKS & OPEN FLAME. HEAT MAY CAUSE PRESSURE
BUILD-UP IN CLOSED CNTNRS. WATER MAY BE USED TO COOL.
* Accidental Release Measures *
Spill Release Procedures:REMOVE SOURCES OF IGNITION. VENTILATE & REMOVE
W/INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:CONTENTS ARE COMBUSTIBLE. KEEP AWAY
FROM HEAT & OPEN FLAME. USE APPROVED BONDING & GROUNDING
PROCEDURES. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:TRANSFER ONLY TO APPROVED, PROPERLY MARKED
CONTAINERS.
* Physical/Chemical Properties *
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:PIGMENTED COLORED LIQUID W/SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE - CARBON DIOXIDE, CARBON
MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS. DISPOSE OF I/A/W FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:FOR CONCENTRATE, AVOID BREATHING MISTS OR VAPORS
CONTAINING PRODUCT.
EXPOSURE.
Supplemental Safety and Health
NK
* Product Identification *
* Composition/Information on Ingredients *
Other REC Limits:1 MG/M3
OSHA PEL:1 MG/M3
ACGIH TLV:STEL 3 MG/M3
Other REC Limits:NOT EST.
Ingred Name:THIS PRODUCT CONTAINS NO OTHER COMPONENT CONSIDERED
Fraction by Wt: NA
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: CAN CAUSE SEVERE
IRRITATION. POSSIBLE CHEMICAL BURNS. HARMFUL IF SWALLOWED. CAN
CAUSE CHEMICAL BURNS OF MOUTH, THROAT, STOMACH. IF INHALED VAPORS
CAUSE IRRITATION INCLUDING BURNING TASTE. S NEEZING, CAUGHING,
DIFFICULTY BREATHING. USE SOLUTION MAY BE IRRITANT.
Effects of Overexposure: *INHALATION: IMMEDIATELY REMOVE TO FRESH
Medical Cond Aggravated by Exposure:PEOPLE W/ASTHMA AND LUNG PROBLEMS
MAY BE MORE AFFECTED.
* First Aid Measures *
First Aid:EYES: IMMED FLUSH W/PLENTY COOL RUNNING WATER. REMOVE
TO ENSURE RINSING ENTIRE EYE. CALL DR. SKIN: IMMED FLUSH W/PLENTY
CLOTHES BEFORE REUSE. INGEST: RINSE MOUTH THEN DRI 1-2 LARGE
GLASS WATER/MILK. DONT INDUCE VOMITING. NEVER GIVE ANYTHING BY
MOUTH TO UNCONSCIOUS. *
* Fire Fighting Measures *
Extinguishing Media:PRODUCT DOES NOT SUPPORT COMBUSTION.
Fire Fighting Procedures:NONE
* Accidental Release Measures *
Spill Release Procedures:RINSE SMALL AMOUNTS TO DRAIN WHERE POSSIBLE.
DIKE OR DAM LARGE SPILLS. PUMP TO CONTAINERS OR SOAK UP ON INERT
ABSORBENT. FLUSH RESIDUE TO SANITARY SEWER. RINSE AREA THOROUGHLY.
*Handling and Storage *
Handling and Storage Precautions:USE SOLUTION PH: 2.5
* Physical/Chemical Properties *
Spec Gravity:1.1
pH:1.2
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR BLUE LIQUID, CHARACTERISTIC ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CAN REACT VIOLENTLY W/ALKALINE MAT'LS .. DON'T MIX W/CHLORINATED
DETERGENTS/SANITIZERS - WILL CAUSE HAZARDOUS VAPORS.
Stability Condition to Avoid:MIX ONLY W/WATER.
* Disposal Considerations *
Waste Disposal Methods:CONSULT STATE & LOCAL AUTHORITIES FOR
RESTRICTIONS ON DISPOSAL OF CHEMICAL WASTE. UNUSED PRODUCT AS A
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
* Product Identification *
Preparer's Name:DOD HMIS/DGSC-SSH
* Composition/Information on Ingredients *
Ingred Name:ASBESTOS, CHRYSOTILE
OSHA PEL:0.2 FIBERS/CC
Ingred Name:ASBESTOS & NICKEL ALLOY & STEEL COMPOSITION
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
*Handling and Storage *
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
* Physical/Chemical Properties *
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
* Disposal Considerations *
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:RESPIRATOR WILL NOT NORMALLY BE NECESSARY. USE
NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR OR RESPIRATOR FOR
FOR REGULATIONS PERTAIN ING TO RESPIRATOR USE.
Ventilation:NORMAL ROOM VENTILATION IS SUFFICIENT. SUPPLEMENT WITH
LOCAL EXHAUST IF PEL/TLV IS EXCEEDED.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL- TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
MSDS WAS WRITTEN BY DGSC-SSH BECAUSE POLYMER RESEARCH COULD NOT PROVIDE
MSDS. MSDS COVERS THE ELECTROLYTE.
* Product Identification *
Preparer's Name:DGSC-SSH
* Composition/Information on Ingredients *
Ingred Name:SILVER (SARA III)
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ZINC (SARA III)
Other REC Limits:NONE SPECIFIED
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
Other REC Limits:NONE SPECIFIED
OSHA PEL:C, 2 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:BATTERY SHOULD NOT BE HAZARDOUS UNLESS
THE ELECTROLYTE IS LEAKING FROM THE CASE. ELECTROLYTE IS CORROSIVE
TO BODY TISSUES. IT IS TOXIC BY CORROSIVITY. AS A SOLUTION OF A
SOLID UNLIKELY TO BE INHALED, BUT WILL ALSO ATTACK THE RESPIRATORY
SYSTEM.
Explanation of Carcinogenicity:THE PRODUCT CONTAINS NO INGREDIENT THAT
IS LISTED BY IARC, NTP OR OSHA AS A CARCINOGEN.
Effects of Overexposure:ELECTROLYTE CONTACT: EYE:SEVERE IRRITATION,
BURNING. SKIN:SLIPPERY FEELING,BURNS. INHALED:(UNLIKELY)
RESPIRATORY IRRITATION,PULMONARY EDEMA. INGESTED:SEVERE IRRITATION
OF G/I TRACT,BURNS, G/I DISTRESS ,NAUSEA,VOMITING.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
* First Aid Measures *
& WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE.
INHALED:REMOVE TO FRESH AIR. RESTORE BREATHING IF NECESSARY.
INGESTED:DO N OT INDUCE VOMITING. GIVE 2 LARGE GLASSESOF MILK OR WA
TER AND GET IMMEDIATE MEDICAL CARE. GIVE NOTHING BY MOUTH IF
UNCONSCIOUS. IF IRRITATION PERSISTS OR IS SEVERE,SEE A DOCTOR.
* Fire Fighting Measures *
Flash Point:NON-FLAMMABLE
Extinguishing Media:PRODUCT IS NON FLAMMABLE. EXTINGUISH FIRE WITH
MEDIA APPROPRIATE FOR SOURCE OF FIRE.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:COVER SPILL WITH SOLID NEUTRALIZER OR
ABSORBER. PUT NEUTRALIZED MATERIAL IN LINED DISPOSAL CONTAINER.
FLUSH RESIDUE WITH WATER.
Neutralizing Agent:BORIC ACID, DILUTE ACETIC ACID.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY AREA. KEEP
CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT CONTAINERS FROM
PHYSICAL DAMAGE.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE MIST. AVOID
CONTACT WITH EYES AND SKIN. WASH THOROUGHLY AFTER HANDLING. FOR USE
AS AN ELECTROLYTE IN BATTERIES ONLY.
* Physical/Chemical Properties *
HCC:B1
pH:UNKNON
Solubility in Water:ELECTROLYTE,COMPLETE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACIDS
Stability Condition to Avoid:HEAT, OVERCHARGE
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:FOR SMALL QUANTITIES: CAUTIOUSLY ADD TO A LARGE
STIRRED EXCESS OF WATER. ADUST THE PH TO NEUTRAL, SEPARATE OUT
SOLIDS AND PACKAGE FOR DISPOSAL. DISPOSAL SHOULD BE MADE IN
ACCORDANCE WITH ALL APPLICABL E FEDERAL, STATE AND LOCAL LAWS AND
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED.
Ventilation:ADEQUATE
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER, WORK
CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
FORMULA CHANGED. FOR PREVIOUS FORMULATION, SEE PNI A UNDER THE SAME
NSN.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:POTASSIUM CYANIDE (SARA III)
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG (CN)/M3
Ingred Name:AMMONIUM,ETHYLHEXADECYLDIMETHYL-,BROMIDE/BRETOL
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE- IRRITATIONS TO SKIN AND EYES.
IF INGESTED, WEAKNESS, DIZZINESS, HEADACHE, NAUSEA, VOMITING. SKIN
ABSORPTION MAY OCCUR. CHRONIC- UNKNOWN. TARGET ORGANS:SKIN, EYES,
CENTRAL NERVOUS SYSTEM.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYE AND SKIN IRRITATION, WEAKNESS, DIZZINESS,
HEADACHE, NAUSEA AND VOMITING
* First Aid Measures *
First Aid:GET MEDICAL HELP IMMEDIATELY. EYE:IMMEDIATELY FLUSH WITH
WATER. INHALED:REMOVE TO FRESH AIR. PROVIDE CYANIDE POISONING
TREATMENT. ORAL :IF CONSCIOUS, GIVE EMETIC (WARM SALT WATER) UNTIL
VOMIT IS CLEAR. IF UNCONSCIOUS, GIVE INHALATION OF AMYL NITRATE (OR
CONTROL CENTER.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:WATER SPRAY, FOAM OR DRY CHEMICAL FOR SURROUNDING
FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA. NEUTRALIZE WITH STRONG
ALKALINE SOLUTIONS OF CALCIUM/SODIUM HYPOCHLORITE. ABSORB USING
TOWELS/ABSORBENT MATERIAL. TRANSFER TO BIO-HAZARD BAGS. FLUSH SPILL
AREA THOROUGHLY WITH WATER TO APPROVED OUTSIDE DRAINAGE.
Neutralizing Agent:POTASSIUM HYDROXIDE + CALCIUM OR SODIUM HYPOCHLORITE
*Handling and Storage *
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE, IN A CLOSED
CONTAINER AWAY FROM INCOMPATIBLE MATERIALS. KEEP OUT OF REACH OF
CHILDREN.
Other Precautions:AVOID EYE OR SKIN CONTACT. WASH THOROUGHLY AFTER
HANDLING AND BEFORE EATING, DRINKING OR SMOKING. AVOID EXCESSIVE
LIGHT.
* Physical/Chemical Properties *
HCC:T2
NRC/State Lic Num:NOT RELEVANT
Melt/Freeze Pt:M.P/F.P Text:NOT KNOWN
Spec Gravity:APPROX. 2.0
Appearance and Odor:YELLOW LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACIDS, ACID SALTS AND OXIDIZERS
Stability Condition to Avoid:CONTACT WITH ACIDS, EXCESSIVE LIGHT
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:SEND TO AN EPA APPROVED WASTE TREATMENT AND
DISPOSAL FACILITY. FOLLOW ALL LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF TLV EXCEEDED, NIOSH/MSHA AIR SUPPLIED RESPRTR
ADVISED IN ABSENCE OF ENVIRNMNTL CONTROL. OSHA REGS ALSO PERMIT
OTHER NIOSH/MSHA RESPIRATOR UNDER SPECIFIED CONDITIONS. IMPLEMENT
ENGINEERING OR ADMINI STRATIVE CONTROLS TO REDUCE EXPOSURE.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL &/OR LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING AND BOOTS.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING OR USING
WASHROOM.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:BJG
* Composition/Information on Ingredients *
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: 9%
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: 3%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHYL ACETATE (SARA III)
Fraction by Wt: 7%
Other REC Limits:NONE RECOMMENDED
Ingred Name:YELLOW LEAD CHROMATE
Fraction by Wt: 4%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIATOMACEOUS SILICA
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: NASAL & RESPIRATORY IRRITATION,
DIZZINESS, FATIGUE, NAUSEA, HEADACHE, UNCONSCIOUS, ASPHIXIATION.
SKIN: PROLONG/REPEAT:IRRIT. POTENTIAL ABSORPTION HAZARD. EYE:
SEVERE IRRITATION, REDNESS, TEARIN G, BLURRED VISION. INGEST: GI
IRRIT, NAUSEA, VOMITING, DIARRHEA. ASPIRATION INTO LUNGS CAN CAUSE
CHEMICAL PHEUMONITIS.
Effects of Overexposure:ACUTE: IRRITATION OR SKIN, EYES, MUCOUS
MEMBRANES, DRYING, DEFATTING OF SKIN. AVOID INGESTION AND BREATHING
OF VAPORS. CHRONIC: EYE, LIVER, KIDNEY, AND CENTRAL NERVOUS SYSTEM
DAMAGE MAY OCCUR.
Medical Cond Aggravated by Exposure:MAY PROVOKE ASTHMATIC RESPONSE IN
PERSONS WITH ASTHMA WHO ARE SENSITIVE TO AIRWAY IRRITANT.
* First Aid Measures *
First Aid:IF SPILLED ON SKIN OR IN THE EYE, WASH WITH COPIOUS
QUANTITIES OF WATER, CONTACT PHYSICIAN IF SPILLED IN THE EYE(S). IF
INGESTED, DO NOT INDUCE VOMITING, KEEP PERSON WARM, QUIET AND
CONTACT PHYSICIAN.BREATHING: REMOVE PERSON TO FRESH AIR GIVE
OXYGEN IF BREATHING DIFFICULT; GIVE ARTIFICIAL RESPIRATION IF
BREATHING STOPS. KEEP PERSON WARM AND GET MEDICAL HELP.
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS WITH A
FULL FACE PIECE OPERATED IN PRESSURE-DEMAND OR OTHER POSITIVE
PRESSURE MODE WHEN FIGHTING FIRES.
Unusual Fire/Explosion Hazard:VAPORS HEAVIER THAN AIR MAY TRAVEL ALONG
GROUND/MOVED BY VENT & IGNITED BY HEAT, PILOT LIGHTS,FLAMES & IGNIT
SOURCES AT LOCATIONS DISTANT FRM MATRL HANDLING PT.
* Accidental Release Measures *
Spill Release Procedures:DIKE UP AND CONTAIN SPILL WITH INERT MATERIAL,
MOP UP AND PLACE MATERIAL INTO CONTAINERS. PREVENT RUN-OFF TO
SEWER, STREAMS. NOTIFY AUTHORITIES.
*Handling and Storage *
Handling and Storage Precautions:DO NOT STORE OR USE IN HIGH
TEMPERATURE AREAS OR NEAR HEAT, SPARKS OR FLAME. KEEP CLOSURE TIGHT
AND CONTAINER UPRIGHT TO PREVENT LEAK.
Other Precautions:STORE IN WELL VENTED AREAS. AVOID CONTACT WITH OR
BREATHING OF VAPORS RELEASED DURING CURING PROCESS. DON'T TAKE
INTERNALLY. AVOID CONTACT WITH SKIN & EYES. AVOID BREATHING OF
VAPORS OR SPRAY MIST. OB SERVE HAZARD PRECAUTIONS GIVEN IN MSDS.
* Physical/Chemical Properties *
Vapor Density:> AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NOT SOLUBLE IN WATER
Appearance and Odor:GREEN VISCOUS LIQUIDS WITH LACQUER SOLVENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NEVER USE WELDING OR CUTTING TORCH ON OR
NEAR DRUMS (EVEN EMPTY)BECAUSE PRODUCT(EVEN RESIDUE)CAN IGNITE
EXPLOSIVELY.
* Disposal Considerations *
Waste Disposal Methods:SMALL: ALLOW VOLATILE PORTION TO EVAPORTATE
(HOOD).ALLOW TIME FOR VAPOR TO CLEAR HOOD DUCT.DISPOSE REMAINING
MAT'L IN ACCORD W/REGULATIONS. LRG: DESTROY BY LIQUID INCINERATION.
DISPOSE CONTAM ABSORB I N LANDFILL IN ACCORD W/LOCAL,STATE,FED
REGS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:NONE NORMALLY REQUIRED.
Other Protective Equipment:NOT NORMALLY NEEDED.
Supplemental Safety and Health
* Product Identification *
CAGE:0TAJ8
CAGE:0TAJ8
* Composition/Information on Ingredients *
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NAUSEA, VOMITING, SHORTNESS OF BREATH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NAUSEA, VOMITING, SHORTNESS OF BREATH.
* First Aid Measures *
INHALATION: REMOVE TO FRESH AIR. GIVE CPR IF NEEDED. INGESTION:
INDUCE VOMITING IF CONSCIOUS. NEVER INDUCE VOMITING TO AN
UNCONSCIOUS PERSON . OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:AS APPROPRIATE FOR SURROUNDING MATERIAL.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:FLUSH TO DRAIN USING PLENTY OF WATER.
*Handling and Storage *
Handling and Storage Precautions:STORE PER LABEL DIRECTIONS.
Other Precautions:READ & FOLLOW ALL LABEL DIRECTIONS.
* Physical/Chemical Properties *
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR COLORLESS TO PALE YELLOW SOLUTION W/SWEET
AROMA TO NONE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE ONLY NIOSH/MSHA APPROVED RESPIRATORS
Ventilation:DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT BUILD-UP
OF VAPORS.
Other Protective Equipment:EYE WASH, SAFETY SHOWER
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS THOROUGHLY AFTER HANDLING, BEFORE EATING OR
SMOKING.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:FORMALDEHYDE, FORMALIN (2A CARCINOGEN BY NTP, IARC, OSHA)
INTENDED CHANGE
Fraction by Wt: <0.1%
Ingred Name:GLYCOL ETHERS, DIETHYLENE GLYCOL, 2,2-OXYBISETHANOL
Ingred Name:TITANIUM DIOXIDE, TIO2
Ingred Name:ZINC OXIDE
Ingred Name:ACRYLIC COPOLYMER
Ingred Name:TALL OIL FATTY ACIDS, PENTAERYTHRITOL, ISOPHTHALIC ACID
Fraction by Wt: 1-5%
Ingred Name:WATER
Ingred Name:CLAY (KAOLIN)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY TRACT
IRRITATION. SKIN/EYES: IRRITATION. INGESTION: LARGE AMOUNTS COULD
CAUSE SERIOUS INJURY.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:INHALATION: MUCOUS MEMBRANE IRRITATION,
DROWSINESS, DIZZINESS, &/OR LIGHTHEADEDNESS, HEADACHE, NAUSEA,
ALLERGIC SENSITIZATION. SKIN: DERMATITIS, DIZZINESS, &/OR
LIGHTHEADEDNESS, HEADACHE, NAUSEA. MAY BE ABSORBED.
Medical Cond Aggravated by Exposure:EYES, SKIN, RESPIRATORY, LUNG,
KIDNEY, LIVER & NERVOUS SYSTEM DISORDERS.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED
BREATHING. HAVE TRAINED PERSON GIVE OXYGEN IF NECESSARY. SKIN: WASH
OFF QUICKLY W/PLENTY OF WATER, THEN SOAP & WATER. EYES: FLUSH
ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:DRY CHEMICAL OR FOAM
Fire Fighting Procedures:CLOSED CONTAINERS MAY BURST IF EXPOSED TO
EXTREME HEAT OR FIRE.
Unusual Fire/Explosion Hazard:WATER MAY BE USED TO COOL & PROTECT
EXPOSED CONTAINERS.
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA. COLLECT SPILLS W/ABSORBENT
MATERIAL.
*Handling and Storage *
ONLY W/ADEQUATE VENTILATION. KEEP CONTAINERS TIGHTLY CLOSED &
UPRIGHT WHEN NOT IN USE. DON'T TAKE INTERNALLY.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID CONTACT W/SKIN,
EYES & BREATHING OF VAPORS. AVOID CONDITIONS WHICH RESULT IN
FORMATION OF INHALABLE PARTICLES SUCH AS SPRAYING OR ABRADING
(SANDING) PAINTED SURFAC ES.
* Physical/Chemical Properties *
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, HYDROFLUORIC ACID
Stability Condition to Avoid:ELEVATED TEMPERATURES
Hazardous Decomposition Products:CO, CO2
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE W/ALL APPLICABLE
REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WELL VENTILATED AREA-RESP NOT REQ. RESTRICTED
VENT-NIOSH CHEMICAL CARTRIDGE MAY BE REQ. IF SPRAYING, MECH
PREFILTER MAY BE REQ. IF TLV ARE EXCEEDED, USE A PROP FITTED
Ventilation:PROVIDE DILUTION/LOCAL EXHAUST VENTILATION TO KEEP
CONCENTRAOF HAZARDOUS SUBSTANCES BELOW EXPOSURE LIMITS STATED.
Other Protective Equipment:EYEWASH FACILITY, SAFETY SHOWER.
Work Hygienic Practices:WASH WITH SOAP AND WATER HANDS/FACE THROUGHLY
BEFORE EATING OR DRINKING.
Supplemental Safety and Health
NK
* Product Identification *
Kit Part:Y
Preparer's Name:W.A. ELLISON
* Composition/Information on Ingredients *
Ingred Name:N-BUTYL ALCOHOL (SARA III)
Ingred Name:PROPYLENE GLYCOL MONOMETHYL ETHER
Ingred Name:TOLUENE (SARA III)
Ingred Name:DIETHYLENE TRIAMINE
OSHA PEL:1 PPM
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SWALLOWING: CAN CAUSE GASTROINTESTINAL
IRR/ NAUSEA/VOMIT. ASPIRATION OF MAT'L MAYCAUSE CHEM PNEUMONITIS.
INHALATION: NOSE/THROAT IRRITA. HIGH CONCENTRATION MAY CAUSE
CENTRAL NERVOUS SYSTEM DEPRESSION CHAR BY
HEADACHES/DIZZINESS/NAUSEA/ CONFUSION. EYE: MAY CAUSE EYE IRRITA.
SKIN: MAY CAUSE DEFATTING AND IRRITATION.
Effects of Overexposure:REPORTS HAVE ASSOCIATED PROLONGED AND REPEATED
OCCUPATIONAL OVEREXPOSURE TO SOL-VENTS WITH PERMANENT BRAIN AND
NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING AND INHALING THE CONTENTS MAY BE HARMFUL OR FATAL.
OVEREXPOSURE TO TOLUENE MAY CAUSE LIVER DAMAGE AND CONTACT MAY
CAUSE DERMATITIS.
* First Aid Measures *
First Aid:SWALLOWING: DO NOT INDUCE VOMITING/GET MED ATTN. INHALATION:
REMOVE TO FRESH AIRIF BREATHING HAS STOPPED GIVE CPR. GET MED ATTN.
ATTN. S KIN: REMOVE CONTAMINATED CLOTHING. WASHAFFECTED AREA.
OBTAIN MED ATTN IF IRR'N PERSISTS. TREATMENT REQ FOR OVER- EXPOSURE
S/B DIRECTED AT THE CONTROL OF SYMPTOMS AND THE CLINICAL
CONDITIONS.
* Fire Fighting Measures *
Extinguishing Media:USE NFPA CLASS B FIRE EXTINGUISHERS. POLYMER FOAM
IS PREFERRED FOR LARGE FIRES.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS. WATER
TO COOL CONT TO PREVENT POSSIBLE AUTO-IGNITION OR EXPLOSION. IF
WATER IS USED, FOG NOZZLES ARE PREFERABLE.
Unusual Fire/Explosion Hazard:DURING EMERGENCY CONDITIONS, OVEREXPOSURE
TO DECOMPOSITION PRODUCTS MAY CAUSE A HEALTH HAZARD. SYMP MAY NOT
BE IMMED APPARENT. GET MED ATTN. WARNING! FLAMMABLE
* Accidental Release Measures *
Spill Release Procedures:ELIM ALL IGNITION SOURCES. DIKE/CONTAIN SPILL
WITHINERT MAT'L. TRANSFER LIQ'S/ABSORBENT DIKING MAT'LIN COVERED
METAL CONT'S FOR RECOVERY/DISPOSAL. USEONLY NON-SPARKING TOOLS.
PREVENT CONTAM OF SEWERS/ STREAMS/GROUNDWATER W/SPILLED MAT'L/USED
ABSORBENT
*Handling and Storage *
Other Precautions:AVOID SKIN CONTACT. DO NOT REUSE EMPTY CONT. DO NOT
TAKE INTERN. CONT'ER S/B GROUNDED AND BONDED TO THE RECEIVING
CONTAINER. DO NOT WELD/BRAZE OR CUT CONT'R.NEVER USE PRESSURE TO
EMPTY. DRUM IS NOT A PRESSURE VESSEL. CLOSE AFTER EA USE.
* Physical/Chemical Properties *
HCC:F3
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:NO
STRONG ACIDS OR ALKALINE MATERIALS. OXIDIZING MATERIALS. ACCELERATORS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT AND SOURCES OF
IGNITION.
Hazardous Decomposition Products:BURNING, INCLUDING WHEN HEATED BY
WELDING OR CUTTING, WILL PRODUCE SMOKE, CARBON MONOXIDE AND CARBON
DIOXIDE.
Conditions to Avoid Polymerization:KEEP AWAY FROM HEAT, SPARKS AND
FLAME.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE ONLY IN EPA PERMITTED FACILITY.
DISPOSEONLY IAW FED/STATE/LOCAL REGS. DO NOT INCINERATE CLOSED
CONTAINERS. OBSERVE PRECAUTIONS FOR DIS- POSAL OF FLAMMABLE MAT'S.
CONTAMINATED ABSORBENT MAYBE DISPOSED IN A HAZARDOUS WASTE
LANDFILL.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENT, WEAR A PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESPIRATOR APPROVED BY NIOSH FOR PROTECTION
AGAINST MATERIALS IN SECTION 2. WHEN SANDING/ABRADING DRIED FILM,
WEAR DUST/MIST RESP APPROVED BY NIOSH FOR DUST WHICH MAY BE
GENERATED FROM THIS PRODUCT, UNDERLYING PAINT, OR THE ABRASIVE.
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF
EXPOSURE TO MATERIALS IN SECTION 2 IS MAINTAINED BELOW APPLICABLE
EXPOSURE LIMITS. (SUPDAT)
Other Protective Equipment:EYE WASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
OTHER PREC: DUSTS ARE LISTED IN SECTION 2, APPLICABLE LIMITS FOR
* Product Identification *
* Composition/Information on Ingredients *
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICA, CRYSTALLINE-QUARTZ
= Wt:.3
OSHA PEL:see Table Z-3
ACGIH TLV:0.1 MG/M3
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS
OSHA PEL:see Table Z-3
ACGIH TLV:2 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ROUTES OF EXPOSURE: EXPOSURE MAY BE BY
INHALATION AND/OR SKIN OR EYE CONTACT, DEPENDING ON CONDITIONS OF
USE. TO MINIMIZE EXPOSURE, FOLLOW RECOMMENDATIONS FOR PROPER USE,
VENTILATION, AND PERSONAL PRO TECTIVE EQUIPMENT. ACUTE: IRRITATION
OFEYES, SKIN AND UPPER RESPIRATORY SYSTEM. IN A CONFINED AREA
VAPORS IN HIGH CONCENTRATION MAY CAUSE HEADACHE, NAUSEA OR
DIZZINESS. SIGNS AND SYMPTOMS OF OVEREXPOS URE: REDNESS AND ITCHING
OR BURNING SENSATION MAY INDICATE EYE OR EXCESSIVE SKIN EXPOSURE.
CHRONIC: CRYSTALLINE SILICA (QUARTZ, CRISTOBALITE) IS LISTED BY
IARC AND NTP. LONG TERM EXPOSURE TO HIGH LEV ELS OF SILICA DUST
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ: IARC
REASONABLY ANTICIPATED TO BE HUMAN CARCIN.
Effects of Overexposure:HLTH HAZ: WHICH CAN OCCUR ONLY WHEN SANDING OR
ABRADING THE DRY FILM, MAY CAUSE LUNG DAMAGE (SILICOSIS) AND
POSSIBLY CANCER. ETHYLENE GLYCOL IS CONSIDERED AN ANIMAL TERATOGEN.
IT HAS BEEN SHOWN TO CAU SE BIRTH DEFECTS IN RATS AND MICE AT HIGH
DOSES WHEN GIVEN IN DRINKING WATER OR BY GAVAGE. THERE IS NO
EVIDENCE TO INDICATE IT CAUSES BIRTH DEFECTS IN HUMAN. PROLONGED
OVEREXPOSURE TO SOLVENT INGREDIE NTS IN SECTION 2 MAY CAUSE ADVERSE
EFFECTS TO THE LIVER AND URINARY SYSTEMS.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
* First Aid Measures *
First Aid:INHALATION: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE
BREATHING. KEEP WARM AND QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY
WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER
BEFORE RE-USE. EYES: FLUSH EYES WITH LARGE AMOUNTS OF WATER FOR AT
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. GIVE CONSCIOUS PATIENT
SEVERAL GLASSES OFWATER. IF VOMITING IS NOT SPONTANEOUS, INDUCE
VOMITING BY HAVING THE PATIENT GENTLY TOUCH THE BACK OF HIS THROAT
WITH A FINGER. KEEP AIRWAY CLEAR. SEEK MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:N.A
Upper Limits:N.A
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG
NOZZLES ARE PREFERABLE. WATER MAY BE USED TO COOL CLOSED CONTAINERS
TO PREVENT PRESSU RE BUILD-UP AND POSSIBLE AUTOIGNITION OREXPLOSION
WHEN EXPOSED TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO THE
BUILD-UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT. FLAMMABILITY
CLASSIFICATION: NOT APPLICABLE. HMIS CODE: HEALTH 3 FLAMMABILITY 1
REACTIVITY 0.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
*Handling and Storage *
Handling and Storage Precautions:DOL STORAGE CATEGORY: 3B. KEEP
CONTAINER CLOSED WHEN NOT IN USE. TRANSFER ONLY TO APPROVED
CONTAINERS WITH COMPLETE AND APPROPRIATE LABELING. DO NOT TAKE
INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:PREC TO BE TAKEN IN USE: USE ONLY W/ADEQUATE VENT.
AVOID BRTHG VAP & SPRAY MIST. AVOID CNTCT W/SKIN & EYES. THIS
COATING MAY CONTAIN MATLS CLASSIFIED AS NUISANCE PARTICULATES
(LISTED "AS DUST" IN SECT ION 2) WHICH MAY BE PRESENT AT HAZ LEVELS
ONLY DURING SANDING/ABRADING OF DRIED FILM. IF NO SPECIFIC
(SUPDAT)
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:N.A.
Vapor Pres:SEE INGREDIENTS
Vapor Density:HVR/AIR
pH:8.3
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:N.A.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BY FIRE: CARBON DIXIDE, CARBON
MONOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:WASTE FROM THIS PRODUCT IS NOT HAZARDOUS AS
CONTAINER. DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE, AND LOCAL
REGULATIONS REGARDING POLLUTION.
* Regulatory Information *
Federal Regulatory Information:TSCA CERTIFICIATION: ALL CHEMICALS IN
THIS PRODUCT ARE LISTED, OR ARE EXEMPT FROM LISTING, ON THE TSCA
INVENTORY.
PRODUCT CONTAINS CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO
CAUSE CANCER AND BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:MATERIAL SHOULD BE HANDLED/TRANSFERRED IN AN APPROVED FUME
HOOD OR WITH ADEQUATE VENTILATION.
Other Protective Equipment:EYE WASH AND SAFETY EQUIPMENT SHOULD BE
READILY AVAILABLE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. DO NOT TAKE
INTERNALLY.
Supplemental Safety and Health
NONE
* Product Identification *
Product ID:AMMONIUM IRON (III) SULFATE
* Composition/Information on Ingredients *
Ingred Name:AMMONIUM FERRIC SULFATE
Other REC Limits: RECOMMENDED
ACGIH TLV:1 MG(FE)/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED CONTACT MAY CASUE SKIN
IRRITATION.
Explanation of Carcinogenicity:TEST ON LABORATORY ANIMALS INDICATE
MATERIAL MAY PRODUCE ADVERSE MUTAGENIC EFFECTS.
Effects of Overexposure: SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NO DATA AVAILABLE.
* First Aid Measures *
First Aid:GET MEDICAL ASSISTANCE FOR ALL CASES OF OVEREXPOSURE. EYES:
FLUSH THOROUGHLY WITH WATER. SKIN: WASH WITH SOAP AND WATER
THOROUGHLY. INHALATION: REMOVE TO FRESH AIR. INGESTION: IF
CONSCIOUS, INDUCE VOM ITING.
* Fire Fighting Measures *
Extinguishing Media:ANY SUITABLE FOR OTHER MATERIAL INVOLVED.
Fire Fighting Procedures:WEAR ELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES ON THERMAL
DECOMPOSITION.
* Accidental Release Measures *
Spill Release Procedures:TAKE UP & CONTAINERIZE FOR PROPER DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE. HEAT MATERIAL ONLY IN A FUME HOOD. DO NOT BREATHE DUST. DO NOT
GET IN EYES. DO NOT TAKE INTERNALLY.
Other Precautions:AVOID PROLONGED OR REPEATED SKIN CONTACT. WASH
THOROUGHLY AFTER HANDLING.
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:SLOUBLE
Appearance and Odor:PALE VIOLET ODORLESS. CRYSTALS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:EXTREME HEAT.
Hazardous Decomposition Products:-NH*3, OXIDES OF SULFUR, OXIDES OF
NITROGEN.
* Disposal Considerations *
Waste Disposal Methods:TO BE PERFORMED IN COMPLIANCE WITH ALL CURRENT
LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NEEDED FOR PROPER USE I/A/W LABEL
DIRECTIONS. NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN .
Ventilation:PROVIDE LOCAL EXHAUST TO KEEP TLV OF SECTION II INGREDIENTS
BELOW ACCEPTABLE LIMITS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:MINERAL SPIRITS
Ingred Name:OXYGENATED HYDROCARBON BLEND
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PETROLEUM GAS (LIQUEFIED); (LIQUEFIED PETROLEUM GAS)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES:MAY CAUSE LIGHT IRRITATION
BUT DOES NOT INJURE EYE TISSUE. SKIN:FREQUENT OR PROLONGED CONTACT
MAY CAUSE IRRITATION. INHALATION:INHAL OF MIST CAN CAUSE IRRIT OF
NASAL & RESP PASSAGES. ABUSIV E/EXCESSIVE INHAL MAY CAUSE IRRIT TO
UPPER RESP TRACT, DIZZ, NAUS, & OTHER CNS EFTS. INGEST:CAN CAUSE
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:GI IRRIT, NAUS, VOMIT & DIARR. ASPIR
OF MATL INTO LUNGS CAN CAUSE CHEMICAL PNEUM. MINIMAL TOXICITY.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
MINS WHILE HOLDING UPPER & LOWER LIDS OPEN. IF IRRIT PERSISTS GET
MED ATTN IMMED. SKIN:WASH W/SOAP & WATER. IF IRRIT PERSISTS SEEK
MED ATTN. I NHAL:REMOVE TO FRESH AIR. SEEK MED ATTNIMMED. IF BRTHG
STOPS GIVE ARTF RESP. INGEST:DO NOT INDUCE VOMIT. SEEK MED ATTN
IMMED.
* Fire Fighting Measures *
Flash Point Method:TOC
Extinguishing Media:FOAM, CO*2, DRY MEDIA.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . COOL FIRE EXPOSED CONTAINERS TO PREVENT RUPTURING.
CAUSE BURSTING.
* Accidental Release Measures *
Spill Release Procedures:ALLOW PROPELLANT TO EVAP. MAINTAIN LOC EXHAUST
& ADEQ VENT. NO SMKNG. KEEP SPKS, HEAT SOURCES & OPEN FLAME FAR
AWAY FROM SPILL/LEAK. COVER W/ABSORB MATL & SWEEP UP. WASH AREA TO
PVNT SLIPPING. DISPOSE OF SOAKED ABSORB MATL I/A/W FED, STATE&
(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN. FOR
INDUST & INSTITUTIONAL USE ONLY. STORE IN COOL, DRY AREA AWAY FROM
HEAT OR OPEN FLAME.
* Physical/Chemical Properties *
Vapor Density:>1
Spec Gravity:SUPDAT
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:SLIGHT
Appearance and Odor:BLACK LIQUID, SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:AEROSOL CANS, WHEN EMPTIED & DEPRESSURIZED
THROUGH NORMAL USE POSE NO DISP HAZ & SHOULD BE RECYCLED. CONSULT
FEDERAL, STATE AND LOCAL AUTH FOR APPROVED PROCEDURES.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MESA APPR SCBA/AIR SUPP RESPIR.
Ventilation:LOCAL EXHAUST TO MAINTN BELOW TLV.
Other Protective Equipment:WEAR FULL PROTECTIVE CLOTHING.
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS.CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE,THROAT.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Effects of Overexposure:INHAL:RESP TK IRRIT;
SKIN/EYE;IRRIT,INFLAM,CHLROACNE; MAY CAUSE LIVER DAMAGE
* First Aid Measures *
First Aid:INHAL:RMV TO FRESH AIR. IF NOT BRTHNG GIVE CPR, IF BRTHNG
DIFF,GIVE OXYGEN. EYE:IMMED FLUSH W/PLENTY OF WATER. SKIN:WASH
W/SOAP&WATER. RMV CONTAM CLTHNG&SHOES. INGEST:INDUCE VOMIT. RPT
UNTIL VOMIT IS CLEAR. NOTHG BY MOUTH IF UNCONSC. GET MEDICAL ATTN
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:MATL IS NON-FLAMMABLE BUT MAY GENERATE
TOXIC GASES IN HEAT OF FIRE
* Accidental Release Measures *
Spill Release Procedures:EVAC NON-ESSENTL PERSONNEL. VENT SPIL AREA.
WEAR PROTECT EQUIPT. STOP LEAK. SOAK UP LIQUID W/NON-REACTIVE MATL
(SAND, DIRT, ETC) OR RMV BY DIKE & PUMPING OR OTHER SUITABLE MEANS.
CLEAN AREA W/SUITABLE SAFETY SOLVENT. LAUNDER CONTAMINATED
CLOTHING.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL CONTACT. KEEP
CONTAINERS TIGHTLY CLOSED
Other Precautions:CHLORODIPHENYLS MAY ATTACK SOME TYPES OF RUBBER AND
PLASTIC. DO NOT USE CONTAMINATED WORK CLOTHING. WASH/SHOWER AFTER
EXPOSURE TO PCB'S.
* Physical/Chemical Properties *
HCC:Z3
Solubility in Water:NEGLIGIBLE
Appearance and Odor:PALE YELLOW VISCOUS LIQUID W/HYDROCARBON ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:SEE OTHER PRECAUTIONS
Hazardous Decomposition Products:HYDROGEN CHLORIDE, CO, & OTHER
TOXIC/IRRITATING GASES/FUMES.
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQD. GEN. V.HIGH TEMP
INCINERATION. IAW ALL LOCAL, STATE, FEDERAL & REGULATIONS.
PERMITTED DISPOSAL OPERATOR REQUIRED.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NOT REQUIRED UNDER NORMAL CONDITIONS OF USE.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:IMMEDIATELY REMOVE CONTAMINATED CLOTHING. WASH
HANDS DURING BREAKS & AT END OF WORK.
Supplemental Safety and Health
FIRST AID PROC:INGEST:REMOVE FROM SOURCE OF EXPOS. IF SIGNS OF TOX
OCCUR, SEEK MED ATTN. NO KNOWN ANTIDOTE. PROVIDE
SYMPTOMATIC/SUPPORTIVE CARE AS NEC. INHAL:REMOVE FROM EXPOS. IF
SIGNS OF TOX OCCUR, SEEK MED ATTN. NO KNOWN ANTIDOTE. PROVIDE
SYMPTOMATIC/SUPPORTIVE CARE AS NEC. EYE PROT:& FULL LENGTH
FACESHIELD .
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ACETIC ACID (CERCLA)
Fraction by Wt: 5%
Ingred Name:INERT INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS MATERIAL IS MODERATELY IRRITATING
TO EYES BUT NOT SKIN. IT IS NOT TOXIC BY INGESTION OR BY SKIN
ABSORPTION. TARGET ORGANS INCLUDE EYES AND POSSIBLY RESPIRATORY
TRACT. SIGNS AND SYMPTOMS:AVAILABLE INFORMATION SUGGESTS THAT
CONTACT WITHEYES COULD RESULT IN SEVERE SWELLING WITH REDNESS THAT
WOULD (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:BE REVERSIBLE. INHALATION OF MISTS
COULD IRRITATE THE NOSE AND UPPER RESPIRATORY TRACT.
Medical Cond Aggravated by Exposure:AVAILABLE INFORMATION SUGGESTS
PRE-EXISTING EYE OR RESPIRATORY AILMENTS.
* First Aid Measures *
First Aid:EYES:REMOVE FROM SOURCE OF EXPOS. FLUSH W/COPIOUS AMTS OF
SEEK MED ATTN IMMED. NO KNOWN ANTIDOTE. PROVIDE
SYMPTOMATIC/SUPPORTIVE CARE AS NEC. SKIN:REMOVE FROM SOURCE OF
EXPOS.FLUSH W/COPIOUS AMTS OF WATER. IF IRRIT PERSISTS/SIGNS OF TOX
SYMPTOMATIC/SUPPORTIVE CARE AS NEC. (SUPP DATA)
* Fire Fighting Measures *
Extinguishing Media:MATERIAL IS NOT FLAMMABLE. EXTINGUISH FIRES
W/AGENTS SUITABLE FOR SURROUNDING MATERIALS.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT DETERMINED.
* Accidental Release Measures *
Spill Release Procedures:CONTAIN SPILL, AVOID SPLASHES & USE
APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT TO MINIMIZE EXPOSURE TO
INCIDENTAL CONTACT W/THIS PRODUCT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:IRRITANT. KEEP OUT OF REACH OF
CHILDREN. PROCS SHOULD BE FOLLOWED TO PREVENT EXPOSURE TO EYES. NO
ADDITIONAL PRECS ARE NEC UNDER NORMAL CNDTNS OF USE.
Other Precautions:KEEP CONTAINER CLOSED. STORE IN A COOL, DRY AREA
SUNLIGHT. KEEP AWAY FROM FOODSTUFFS, BEVERAGES & FOOD. AVOID
CONTACT W/EYES & SKIN.
* Physical/Chemical Properties *
pH:2.1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID W/MILD VINEGAR ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
BASES, OXIDIZING AGENTS, HYDROXIDES, OXIDES, SULFURS, ACID ANHYDRIDES,
PEROXIDES, PERMANGANATES, AMINES.
Stability Condition to Avoid:MATERIAL IS STABLE & NON-REACTIVE UNDER
NORMAL USE.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE I/A/W LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
* Product Identification *
Preparer's Name:DOD HMIS/DGSC-SSH
* Composition/Information on Ingredients *
Ingred Name:ASBESTOS, CHRYSOTILE
OSHA PEL:0.2 FIBERS/CC
Ingred Name:ASBESTOS & STEEL OVERALL COMPOSITION
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
*Handling and Storage *
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
* Physical/Chemical Properties *
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
* Disposal Considerations *
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW
APPLICABLE STANDARDS. APPROVED CHEMICAL MECHANICAL FILTER
RESPIRATOR DESIGNED TO REMOVE A COMBINATION OF PARTICULATE AND
Ventilation:ALL APPLICATION AREAS SHOULD BE VENT IN ACCORDANCE W/OSHA
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ:&/TOX GASES. EFTS OF OVEREXP:SYS DMG. INTENTIONAL MISUSE BY
DELIB CONC & INHALING CONTENTS MAY BE HARMFUL/FATAL. OTHER
PREC:RAGS/WASTE-CNTNG OIL BASED PAINT/VARNISH THAT PRESENT LRG
AIR-TO-O IL INTERFACE WILL OXIDIZE & MAY IGNITE SPONTANEOUSLY &
SHOULD BE PLACED IN METAL CNTNR. KEEP OUT OF REACH OF CHILDREN.
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
Ingred Name:CALCIUM CARBONATE
Ingred Name:EPOXY RESIN
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:OTHER PREC:RAGS/WASTE-CNTNG OIL BASED PAINT/VARNISH THAT
PRESENT LARGE AIR-TO-OIL INTERFACE WILL OXIDIZE & MAY (ING 6)
Ingred Name:ING 5:IGNITE SPONTANEOUSLY & SHOULD BE PLACED IN METAL
CONTAINER. KEEP OUT OF REACH OF CHILDREN.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:IRRIT OF RESP TRACT. PRLNG INHAL
MAY LEAD TO FATIGUE, DROW, DIZZ &/OR LT HEAD, HDCH, LACK OF
COORDINATION, NAUS, VOMIT, CNS DEPRESS, ANESTHETIC EFT/NARCOSIS.
SKIN:IRRIT OF SKIN. PRLNG/RPTD CONT CAN CAUSE DERM, DEFATTING.
EYE:IRRIT OFEYES. PRLNG/RPTD CONT CAN CAUSE BLURRED VISION, REDNESS
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:OF EYES, TEARING OF EYES, SEV EYE
IRRIT. INGEST:AMTS INGEST INCIDENTAL TO CONSUMER & INDUS HNDLG ARE
NOT LIKELY TO CAUSE INJURY; HOWEVER, INGEST OF LRG AMTS MAY CAUSE
LUNG INFLAMM & DMG DUE T O ASPIR OF MATRL INTO LUNGS. NOTICE:RPTS
HAVE ASSOC RPTD & PRLNG OCCUP OVER-EXPOS TO SOLV W/PERM BRAIN &
NERV (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
HAVE TRAINED PERSON GIVE OXYGEN IF NEC. GET EMER MED ATTN.
SKIN:WASH OFF QUICKLY W/PLENTY OF H*2O, THEN SOAP & H*2O; REMOVE
CONTAMD CLTHG. WASH CONTAMD CLTHG BEFORE REUSE. EYE:FLUSH IMMED
EMER MED TREATMENT. INGESTION:IF SWALLOWED, OBTAIN MEDICAL
TREATMENT IMMEDIATELY.
* Fire Fighting Measures *
Flash Point Method:SCC
Lower Limits:SEE INGS
Extinguishing Media:DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL AND PROTECT EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CLSD CNTNRS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT/FIRE. VAP CAN FORM EXPLO MIX IN AIR AT ELEVATED TEMPS.
MAY DECOMP UNDER FIRE CNDTNS EMITTING IRRIT (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION (FLAME, HOT
SURFACES, AND ELECTRICAL, STATIC SPARKS). VENTILATE AREA AND AVOID
BREATHING VAPORS. CONTAIN AND REMOVE WITH INERT ABSORBENT MATERIAL
USING NON-SPARKING TOOL S.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
DEGREE F.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT WELD/FLAME CUT W/OUT
PROPER VENT TO INSURE AREA IS FREE OF FLAMM VAP. DO NOT CUT,
PUNTURE/WELD ON/NEAR CNTNR. ENTRANCE INTO CLSD STOR TANKS-USE
APPROP RESP/AIRLINE FOR P OSS EXPOS TO SOLV/CHEM FUMES. (SUPDAT)
* Physical/Chemical Properties *
Vapor Pres:SEE INGS
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, BASES, AMINES.
Stability Condition to Avoid:ELEVATED TEMPERATURES. CONTACT WITH
OXIDIZING AGENTS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:FOR CONDITIONS OF USE WHERE EXPOSURE TO THE DUST
IS APPARENT, A DUST/MIST RESPIRATOR MAY BE WORN. FOR EMERGENCIES, A
SELF-CONTAINED BREATHING APPARATUS MAY BE NECESSARY.
Ventilation:IN GENERAL, DILUTION VENTILATION IS SATISFACTORY. IF
CONDITIONS OF USE CREATE WORKER DISCOMFORT, LOCAL EXHAUST SHOULD BE
CONSIDERED.
Other Protective Equipment:MAINTAIN EYE WASH FOUNTAIN AND QUICK DRENCH
FACILITIES TO WORK AREA. WEAR CLEAN BODY-COVERING CLOTHING.
Work Hygienic Practices:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Supplemental Safety and Health
CONTACTS SHOULD NOT BE WARNED WHEN WORKING WITH THIS MATERIAL.
* Product Identification *
Product ID:CHARCOAL ACTIVATED (SEE SUPPLEMENTAL)
* Composition/Information on Ingredients *
Ingred Name:ACTIVATED CARBON OR CARBON BLACK OR ACTIVATED CHARCOAL
* Hazards Identification *
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE IRRITATION TO
MUCOUS MEMBRANES. INGESTION: EXTREMELY LARGE ORAL DOSAGES MAY
PRODUCE GASTROINTESTINAL DISTURBANCES. SKIN CONTACT: NO ADVERSE
FFECTS REPORTED. EYE CONTACT: NO ADVER SE EFFECTS EXPECTED BUT DUST
MAY CAUSE MECHANICAL IRRITATION. CHRONIC EXPOSURE: PROLONGED
INHALATION OF EXCESSIVE DUST MAY PRODUCE PULMONARY DISORDERS.
Explanation of Carcinogenicity:NO INFORMATION FOUND.
Effects of Overexposure:INHALATION: IRRITATION TO MUCOUS MEMBRANES.
SINGESTION: GI TRACT DISTURBANCES. EYES: POSSIBLE MECHANICAL
IRRITATION.
Medical Cond Aggravated by Exposure:NO INFORMATION FOUND.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. GET MEDICAL ATTENTION. FOR
ANY BREATHING DIFFICULTY. INGESTION: GIVEE SEVERAL GLASSES OF WATER
TO DRINK TO DILUTE. IF LARGE AMOUNTS WERE SWALLOWED, GET MEDICAL
ADVICE. SKIN EXPOSURE: NOT EXPECTED TO REQUIRE FIRST AID MEASURES.
EYE EXPOSURE: WASH THOROUGHLY WITH RUNNING WATER. GET MEDICAL
ADVICE IF IRRITATION DEVELOPS.
* Fire Fighting Measures *
Extinguishing Media:WATER OR WATER SPRAY.
Fire Fighting Procedures:IN THE EVENT OF FIRE, WEAR FULL-PROTECTIVE
CLOTHING AND NIOSH-APPROVED SELF-CONTAINED BREATHING APPRATUS WITH
FULL FACEPIECE OPERATED IN THE PRESSURE DEMAND OR OTHER POSITIVE
PRESSURE MODE.
Unusual Fire/Explosion Hazard:FINE DUST DISPERSED IN AIR IN SUFFICIENT
CONCENTRATIONS & IN THE PRESENCE OF AN IGNITION SOURCE IS A
POTENTIAL DUST EXPLOSION HAZARD. MINIMUM EXPLOSIVE CONCENTRATION:
ELEVATED TEMPERATURES OR BY CONTACT WITH IGNITION SOURCE.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AREA
OF LEAK OR SPILL. CLEAN-UP PERSONNEL MAY REQUIRE PROTECTION FROM
INHALATION OF DUST. CLEAN UP SPILLS IN MANNER WHICH DOES NOT
DISPERSE DUST INTO THE AIR. USE NONSPARKING TOOLS. PICK UP SPILL
FOR RECOVERY OR DISPOSAL AND PLACE IN A CLOSED CONTAINER.
Neutralizing Agent:NO DATA PROVIDED BY RESPONSIBLE PARTY.
*Handling and Storage *
Handling and Storage Precautions:PROTECT AGAINST PHYSICAL DAMAGE. STORE
IN A COOL, DRY, WELL-VENTILATED AREA, AWAY FROM ANY AREA WHERE THE
FIRE HAZARD MAY BE ACUTE. OUTSIDE OR DETACHED STORAGE IS PREFERRED.
SEPARATE FROM OXIDIZING MA TERIALS. CONTAINERS SHOULD BE BONDED &
GROUNDED FOR TRANSFERS.
Other Precautions:STORAGE AND USE AREAS SHOULD BE "NO SMOKING" AREAS.
USE NON-SPARKING TOOLS AND EQUIPMENT.
* Physical/Chemical Properties *
HCC:F8
Boiling Pt:B.P. Text:NO INFORMATION
Melt/Freeze Pt:M.P/F.P Text:NO INFORMATION
Decomp Temp:Decomp Text:NO INFORMATION
Vapor Pres:NO INFORMATION
Vapor Density:NIF
Evaporation Rate & Reference:NO INFORMATION FOUND
Solubility in Water:INSOLUBLE.
Appearance and Odor:FINE BLACK POWDER. ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
LIQUID AIR AND OXIDIZING MATERIALS.
Stability Condition to Avoid:STABLE UNDER ORDINARY CONDITIONS OF USE
AND STORAGE.
Hazardous Decomposition Products:INVOLVEMENT IN A FIRE CAUSES FORMATION
OF CARBON DIOXIDE AND CARBON MONOXIDE.
Conditions to Avoid Polymerization:STABLE UNDER ORDINARY CONDITIONS OF
USE AND STORAGE.
* Toxicological Information*
Toxicological Information:NO INFORMATION FOUND.
* Ecological Information *
Ecological:NO DATA PROVIDED BY RESPONSIBLE PARTY.
* Disposal Considerations *
Waste Disposal Methods:WHATEVER CANNOT BE SAVED FOR RECOVERY MAY BE
BURNED IN AN APPROVED INCINERATOR OR DISPOSED IN AN APPROVED WASTE
FACILITY. WARNING! SPENT PRODUCT MAY HAVE ABSORBED HAZARDOUS
MATERIALS. ENSURE COMPLIANC E WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
* MSDS Transport Information *
Transport Information:DOT HAZARD CLASS: FLAMMABLE SOLID.
* Regulatory Information *
SARA Title III Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Federal Regulatory Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.
State Regulatory Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF ABOVE TLV, NIOSH SCBA, POS PRESSR HOSE MASK
OR AIR LINE MASK ADVISED. HAVE FULL FACE SHIELD, OPERATED IN
POSITIVE PRESSURE MODE. LIMITED EXPOSURE TIME, FULL FACE MASK
W/ORGANIC VAPOR CARTRIDGE/CANI STER. FORMALLY TRAIN/SCREEN RESPRTR
USER
Ventilation:LOCAL EXHAUST AND MECHANICAL VENTILATION
Other Protective Equipment:SOLVENT RESISTANT APRONS, BOOTS, AND SUITS
MUST BE WORN. DO NOT WEAR CONTACTS AROUND THIS PRODUCT.
Work Hygienic Practices:WASH ALL EXPOSED AREAS WITH SOAP & WATER AFTER
USING THIS PRODUCT. DO NOT SMOKE AROUND THIS PRODUCT. WASH AFTER
HANDLING
Supplemental Safety and Health
WARNING-CONTENTS MAY BE UNDER PRESSURE. OPEN CAUTIOUSLY TO AVOID INJURY
BY SPURTING. TO OPEN, COVER OPENING TO AVOID SPURTING, REMOVE BUNG.
IF IN DOUBT, DO NOT REMOVE BUNG. SEEK SUPERVISION.
* Product Identification *
Product ID:CREST PAINT STRIPPER NO. 7
Preparer's Name:J.D. BENNETT
* Composition/Information on Ingredients *
Ingred Name:METHYLENE CHLORIDE(SARA III)
Other REC Limits:NONE SPECIFIED
Ingred Name:PHENOL (SARA III)
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 PPM
ACGIH TLV:5 PPM
Ingred Name:SODIUM CHROMATE (SARA III)
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.1 PPM
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:EXCESSIVE AMOUNTS: COLLAPSE & DAMAGE
TO HEART. INHALATION: IN CONFINED OR POORLY VENTILATED AREAS,
UNCONSCIOUSNESS & DEATH. THESE HIGH LEVELS MAY ALSO CAUSE CARDIAC
ARRYTHMIAS. UPPER RESP TRACT IRRIT.
Explanation of Carcinogenicity:SODIUM CHROMATE PRESENTS HUMAN CARCIN
RISK. POTENTIALLY CARCIN INSOLUBLE HEXAVALENT CHROMIUM COMPOUNDS
MAY BE FORMED.
Effects of Overexposure:EXCESS EXPOSR:CENTRAL NERV SYS EFFECTS
(MOD:GIDDINESS,HEADACHE,DIZZINESS,NAUSEA.SEVERE:UNCONSCIOUSNESS,DEA
TH). EXCESS EXPOSR:CARABOXYHEMOGLOBINEMIS,IMPAIR BLOOD'S ABILITY TO
TRANSPRT OXYGEN. KIDNEY DA MAGE (URINE OUTPUT CHANGE). LIVER DAMAGE
(APPETITE LOSS,JAUNDICE,UPPER RIGHT ABDOM PAIN). HEART DAMAGED
(SHORT BREATH).
Medical Cond Aggravated by Exposure:PREEXISTING SKIN, EYE & RESP
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT. IMPAIRED
KIDNEY, LIVER, HEART FUNCTIONS FROM PREEXISTING DISORDERS MAY BE
AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
* First Aid Measures *
REUSE CLOTHES.DESTROY CONTAM LEATHER ARTICLES. INHAL:REMOVE TO
FRESH AI R & GIVE OXYGEN IF BREATH DIFFICULT.GIVE ARTIF RESP IF NOT
BREATHING. INGEST:DON'T INDUCE VOMIT.DON'T GIVE LIQ TO
DROWSY,CONVULSE,UNCONSCIOUS.GIVE LRG QTY WATER. IF VOMIT OCCURS,
GIVE LIQUID AGAIN.
* Fire Fighting Measures *
Flash Point Method:COC
Flash Point:NONE TO BOILING
Extinguishing Media:CARBON DIOXIDE, CHEMICAL FOAM, OR A WATER MIST
Fire Fighting Procedures:THERMAL DECOMP PRODUCES TOXIC CHLORINE &
CARBON OXIDES. DON'T ENTER CONFINED FIRE SPACE W/O FULL BUNKER GEAR
INCLUDING POS PRESSR SCBA. COOL EXPOSED CNTR W/WTR.
Unusual Fire/Explosion Hazard:OXIDES OF CARBON & CHLORINE MAY BE
PRODUCED. BOTH OXIDES ARE DANGEROUS TO HUMANS. COOL CONTAINERS
EXPOSED TO HEAT W/WATER. COOL CONTAINER AREAS EXPOSED W/WATER.
* Accidental Release Measures *
Spill Release Procedures:HIGH CORROSIVE. PREVENT BODY CONTACT. WEAR
RESPRTR & FULL BODY PROTECT CLOTHES. VERY SLIPPERY;PREVENT FALLING
INTO PRODUCT. STOP LEAK IF SAFE. DIKE. REMOVE W/VACUUM TRUCK/PUMP
TO STORAGE/SALVAGE TANK. SOAK UP RESIDUE W/ABSORB. PUT IN
CNTNR/SEAL. *
Neutralizing Agent:*FLUSH W/WATER. DISPOSE OF FLUSH SOLUTION AS ABOVE.
*Handling and Storage *
Handling and Storage Precautions:DO NOT STORE IN SUNLIGHT. STORE
BULGING/DISTORTED CNTNRS. DON'T RECYCLE/REUSE CONTAINERS.
Other Precautions:STORE IN COOL, DRY, VENTED AREA. STORE AWAY FROM
OTHER CHEMICALS. KEEP CNTNR CLSD. DON'T USE PRESSURE TO EMPTY
CNTNR. DO NOT GET ON SKIN, EYES OR CLOTHES. DON'T CUT, GRIND, WELD
ON CONTAINER. OBEY HZD WARNING, HANDLE EMPTY CNTNR AS IF FULL.
* Physical/Chemical Properties *
HCC:T4
Vapor Density:>1
Evaporation Rate & Reference:>1 (BU AC=1)
Solubility in Water:SLIGHTLY SOLUBLE
Appearance and Odor:VISCOUS YELLOW LIQUID LIQUID WITH A PHENOLIC ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZERS.
Stability Condition to Avoid:AVOID STRONG OXIDIZERS.
Hazardous Decomposition Products:THERMAL DECOMP: TOXIC OXIDES OF CARBON
AND CHLORINE. OXIDIZERS: CO2, CO, PHOSGENE, & CHLORINE OXIDES
Conditions to Avoid Polymerization:AVOID STRONG OXIDIZERS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF ALL MATERIAL PER STATE, CITY, &
FEDERAL REGULATIONS. DO NOT DISPOSE OR DISCHARGE INTO SEWERS OR
NAVIGABLE WATERS. DO NOT ALLOW PRODUCT TO CONTAMINATE GROUND
WATERS. ANY DISPOSAL PRACTICE MU ST BE IN COMPLIANCE WITH FED,
STATE & LOCAL REGS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:DUST/MIST RESPIR
Ventilation:LOCAL EXHAUST TO MAINTN BELOW TLV.
Other Protective Equipment:FULL PROTECTIVE CLOTHING,SAFETY SHOWER,EYE
WASH STATION
Supplemental Safety and Health
* Product Identification *
Product ID:FERROUS CHLORIDE
* Composition/Information on Ingredients *
Ingred Name:FERROUS (II) CHLORIDE TETRAHYDRATE
OSHA PEL:1 MG/M3 (FE)
* Hazards Identification *
Effects of Overexposure:INH:MILD IRRIT/NUISANC DUST;ING:LOW TOXCTY. LG
QTY CAUSES DIARR/VOMIT;EYE/SKIN:MILD IRRITATION/PAIN.
* First Aid Measures *
First Aid:INHAL:RMV TO FRESH AIR.GIVE CPR/OXYGEN IF BREATHING IS
DIFFICULT.GET MD;INGEST:IMMED INDUCE VOMIT BY GIVING 2 GL OF
WATER.NOTHING BY MOUTH IF UNCONSCIOUS.GET MD IMMED;SKIN/EYES:FLUSH
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
CONTR.
Unusual Fire/Explosion Hazard:NOT CONSIDERED TO BE AN EXPLOSION HAZARD.
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA OF SPILL.CLEAN UP PERSONS NEED
PROTCTV CLOTHG/RESP PROTCTION FM DUST.PICK UP SPILL & PLACE IN A
SUITABLE CONTAINER FOR RECLAMATION OR DISPOSAL IN A METHOD THAT
DOES NOT GENERATE DUST.
*Handling and Storage *
Handling and Storage Precautions:KEEP IN TIGHTLY CLOSED CONTNRS AT
COOL,DRY, VENTILATED PLACE.PROTECT AGAINST PHY DAMAGE.
Other Precautions:AVOID BREATHING DUST.USE W/ADEQUATE VENTILATION.KEEP
CONTAINRS CLOSED.WASH THOROUGHLY AFTER HANDLING.AVOID SKIN,EYES &
CLOTHING CONTACT.
* Physical/Chemical Properties *
HCC:C1
Solubility in Water:COMPLETE
Appearance and Odor:PALE GREEN CRYSTALS.ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ETHYLENE OXIDE, POTASSIUM, SODIUM.
Hazardous Decomposition Products:OXIDES OF CONTAINED METAL &
HALOGEN,POSS MAY BE FREE HALOGEN
* Disposal Considerations *
Waste Disposal Methods:WHATEVER CANNOT BE SAVED FOR RECLAMATION MAY BE
DISPOSD AS HAZ WASTE IN A RCRA APPRVD WASTE DISPOSAL
FACILITY.COMPLY WITH LOCAL,ST.& FEDERAL REGS; SM AMTS OF RESIDUE
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:LRG SPILLS/ENTRY INTO CONFINED SPACES W/INADEQ
VENT, A NIOSH/MSHA APPRVD PRESS DMD, SCBA IS REC. IF
ENGINEERING/ADMIN CONTROLS ARE NOT ADEQ TO MAINTAIN SOLV TLV BELOW
REC LEVS, AN APPROP NIOSH/MSHA AP PRVD RESP SHOULD BE USED.
Ventilation:GENERAL EXHAUST AS NEEDED TO KEEP TLV BELOW RECOMMENDED
LEVELS IF ENGINEERING OR ADMINISTRATIVE CONTROLS ARE NOT ADEQ.
Other Protective Equipment:IMPERVIOUS CLOTHING AND BOOTS.
Work Hygienic Practices:CLEANSE SKIN THORO AFTER CONT, BEFORE WORK
BREAKS & MEALS, AT END OF WORK DAY. PROD IS READILY REMOVED FROM
(SEE ING 3)
Supplemental Safety and Health
FIRE FIGHT PROC:FIREFIGHTING TO THOSE TRAINED TO DO SO. IF LEAK/SPILL
HAS IGNITED, USE WATER SPRAY TO DISPERSE VAPS & TO PROT MEN ATTEMPT
TO STOP LEAK. MINIMIZE BRTHG GASES, VAP, FUMES/DECOMP PRODS. E XPLO
HAZ: TO AN IGNIT SOURCE. TO PVNT FIRE/EXPLO FROM STATIC ACCUM &
DISCHARGE, EFFECTIVELY GROUND PROD TRANSFER SYSTEM.
* Product Identification *
Product ID:EPDM BLACK LAP SEALANT
* Composition/Information on Ingredients *
Ingred Name:HYGIENE PRACT: THE SKIN WITH WATERLESS HAND CLEANERS
FOLLOWED BY WASHING THOROUGHLY WITH SOAP AND WATER.
Ingred Name:NAPHTHA, LIGHT ALIPHATIC SOLVENT
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
Fraction by Wt: <1%
OSHA PEL:SEE TABLE Z3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRITATION, REDNESS. CHRONIC:
EXPOSURE TO RESPIRABLE QUARTZ WILL NOT BE POSSIBLE WITH THIS
PRODUCT UNDER NORMAL CONDITIONS OF USE.
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ: GROUP 2A.
Effects of Overexposure:EYE: CAN CAUSE SEVERE IRRIT, REDNESS, TEARING,
BLURRED VISION. SKIN: CAN CAUSE REDNESS, IRRIT, DEFAT, DERMAT.
INHAL: PRLNGD INHAL OF VAPORS MAY CAUSE IRRIT OF THE RESP TRACT.
INTENTIONAL MISUSE BY DEL IBERATELY CONCENTRATING AND INHALING
VAPOR MAY BE HARMFUL/FATAL. INGEST: CAN CAUSE GI IRRIT, NAUS,
VOMIT, DIARRHEA.
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN, AND
PULMONARY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
* First Aid Measures *
MINUTES, FREQUENTLY FLUSHING UNDER LIDS. SEEK MD. SKIN: WASH WITH
SOAP AND WATER. GET MEDICAL ATTN IF IRRITATION PERSISTS. INHAL:
REMOVE AFFECTE D PERSON TO FRESH AIR, GIVE OXYGEN OR ARTIFICIAL
RESPIRATION AS NECESSARY TO ASSIST BREATHING. GET MED ATTN. INGEST:
DO NOT INDUCE VOMITING. GET MED ATTN.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:0.9%
Upper Limits:6.7%
Extinguishing Media:FOAM, DRY CHEM OR CO*2. WATER MAY BE INEFFECTIVE,
BUT WATER SHOULD BE USED TO KEEP FIRE EXPOSED CONTAINERS COOL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
FOR ENCLSD/CONFINED SPACES/AS OTHERWISE NEEDED. TREAT AS CLASS "B"
FIRE. LIMIT (SEE SUPP DATA)
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & MAY TRAVEL ALONG
GROUND & BE IGNITED BY IGNIT SOURCES DISTANT FROM HNDLG POINT.
RESIDUE IN "EMPTY" CNTNRS MAY EXPLO IF EXPSD (SUPP DATA)
* Accidental Release Measures *
Spill Release Procedures:ELIM ALL IGNIT SOURCES. CONTROL SOURCE OF
SPILL IF SAFE TO DO SO. VENT ENCLOSED AREAS TO PVNT VAPOR ACCUM.
RESTRICT ACCESS BY UNAUTHORIZED PERSONNEL. ABSORB SPILLED PROD
W/VERMICULITE/OTHER ABSORB MAT L. SHOVEL/SCOOP INTO SEALABLE CNTNR
FORDISP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DO NOT STORE/HANDLE NEAR AN IGNIT
SOURCE. KEEP CNTNRS CLSD. EFFECTIVELY GROUND PROD TRANSFER SYSTEM
TO PVNT FIRE/EXPLO FROM STATIC DISCHARGE.
Other Precautions:EMPTY CNTNRS MAY CONTAIN RESIDUAL PRODUCT. DO NOT
REUSE CONTAINERS UNLESS PROPERLY RECONDITIONED. MINIMIZE BRTHG VAP.
AVOID PRLNGD/RPTD CONT W/SKIN. REMOVE CONTAM CLTHG & LAUNDER BEFORE
REUSE.
* Physical/Chemical Properties *
HCC:F3
Vapor Density:3.8
Evaporation Rate & Reference:9.2 (ETHYL ETHER = 1)
Solubility in Water:<0.5%
Appearance and Odor:BLACK PASTE WITH CHARACTERISTIC ALIPHATIC SOLVENT
NAPHTHA ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:IN THE EVENT OF PARTIAL COMBUSTION,
FUMES, SMOKE, CO, ALDEHYDES, AND OTHER DECOMP PRODS MAY BE
RELEASED.
* Disposal Considerations *
Waste Disposal Methods:IF THIS PRODUCT BECOMES A WASTE, IT IS
CONSIDERED A HAZARDOUS WASTE DUE TO IT'S IGNITABILITY. DISPOSE OF
IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL ENVIRONMENTAL AND WASTE
REGULATIONS.
| 1 | gloves_mandatory |
Control Measures
*
*
Preparer Co. when other than Responsible Party Co.
*
Assigned Ind: Y
*
Contractor Summary
*
*
Ingredients
*
OSHA PEL: 0.1 MG/CUM RESP DUST
ACGIH TLV: 0.1 MG/CUM RESP DUST
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: INHALATION OF CRYSTALLINE SILICA DUST MAY CAUSE SILICOSIS,
A DISABLING, PROGRESSIVE & SOMETIMES FATAL PULMONARY FIBROSIS IN THE
LUNGS.
Explanation Of Carcinogenicity: SEE INGREDIENTS.
Signs And Symptions Of Overexposure: COUGH, SHORTNESS OF BREATH, CONGESTION,
CHEST PAIN/ILLNESSES
First Aid: INHALATION: MOVE AWAY TO FRESH AIR AT ONCE. IF BREATHING HAS
STOPPED, PERFORM ARTIFICIAL REPIRATION. EYES: WASH IMMEDIATELY W/LARGE
AMOUNTS OF WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
*
Handling and Disposal
*
Spill Release Procedures: RESTRICT AREA FROM PERSONS NOT WEARING PROTECTIVE
EQUIPMENT & CLOTHING. VENTILATE AREA TO REDUCE DUST CONCENTRATION. CLEAN
UP BY RECOMMENDED DUSTLESS METHODS - WATER/VACUUM.
Waste Disposal Methods: SECURED SANITARY LANDFILL IN ACCORDANCE W/LOCAL, STATE
& FEDERAL REGULATIONS.
Handling And Storage Precautions: USE DUSTLESS SYSTEMS FOR HANDLING, STORAGE
& CLEAN-UP. VENTILATE WORK AREA, TEST FOR PRESENCE & CONCENTRATION OF
RESPERIABLE SILICA.
Other Precautions: MAINTAIN VENTILATION SYSTEM, POST WARNING TO EMPLOYEES WHERE
PRODUCT IS USED, STORED & HANDLED. REGULAR CHEST X-RAY & SPIROMETRY
ARE RECOMMENDED.
*
Fire and Explosion Hazard Information
*
Flash Point Text: NON-COMBUSTIBLE
Fire Fighting Procedures: NO ACUTE HAZARD. AVOID BREATHING VAPORS/DUST.
Unusual Fire/Explosion Hazard: CONTACT W/POWERFUL OXIDIZING AGENTS MAY CAUSE
FIRES.
*
*
Respiratory Protection: USE NIOSH/MSHA APPROVED RESPIRATORS IF EXPOSURE EXCEEDS
0.1 MG/CUM OVER AN 8 HOUR PERIOD.
Ventilation: LOCAL EXHAUST/GENERAL DILUTION TO MEET PELS.
Work Hygienic Practices: PRACTICE GOOD HOUSEKEEPING.
*
Physical/Chemical Properties
*
Solubility in Water: INSOLUBLE
Appearance and Odor: COLORLESS & ODORLESS
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: NONE
Materials To Avoid: OXIDIZING AGENTS. SILICA IS ATTACKED BY HYDROFLUORIC ACID.
Hazardous Decomposition Products: NONE
Hazardous Polymerization Indicator: NO
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Assigned IND: Y
Company Name: HOLLIDAY SAND & GRAVEL CO
Label Required IND: Y
Status Code: C
Origination Code: G
Hazard And Precautions: INHALATION OF CRYSTALLINE SILICA DUST MAY CAUSE
SILICOSIS, A DISABLING, PROGRESSIVE & SOMETIMES FATAL PULMONARY FIBROSIS
IN THE LUNGS.
COUGH, SHORTNESS OF BREATH, CONGESTION, CHEST PAIN/ILLNESSES
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF MIST/VAPORS AREN'T ADEQUATELY CONTROLLED BY
LOCAL VENTILATION, USE APPROPRIATE RESPIRATORY PROTECTION TO
PREVENT OVEREXPOSURE.
Ventilation:GENERAL ROOM VENTILATION IS ADEQUATE. LOCAL EXHAUST
VENTILATION/RESPIRATORY PROTECTION IF SUBSTANTIAL.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:TERRY A MEYERS
* Composition/Information on Ingredients *
Ingred Name:SODIUM HYDROXIDE, CAUSTIC SODA, LYE
Fraction by Wt: 4-8%
Other REC Limits:2MG/M3 CEILING NIOSH
OSHA PEL:2 MG/CUM
ACGIH TLV:2 MG/CUM CEILING
Ingred Name:1,H-BENZOTRIAZOLE (4 OR 5) METHYL SODIUM SALT,
Fraction by Wt: 1-2%
Ingred Name:2-BUTOXYETHANOL (ETHYLENE GLYCOL MONOBUTYL ETHER), BUTYL
CELLOSOLVE, BUTYL GLYCOL, GLYCOL ETHER EB
Fraction by Wt: 1-3%
Ingred Name:N-BUTOXYPROPANOL
Fraction by Wt: 1-3%
Ingred Name:WATER
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION. INGESTION: MAY
CAUSE CORROSIVE DAMAGE TO MOUTH, THROAT, STOMACH. INHALATION: MAY
CAUSE IRRITATION TO NOSE, THROAT & LUNGS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS MAY BE
MORE SUSCEPTIBLE TO IRRITATING EFFECTS.
* First Aid Measures *
WATER. INGESTION: DRINK LARGE AMOUNTS OF WATER/MILK. INHALATION:
REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:NORMAL FIRE FIGHTING PROCEDURES MAY BE USED.
Unusual Fire/Explosion Hazard:CORROSIVE MATERIAL.
* Accidental Release Measures *
Spill Release Procedures:ABSORB W/OIL-DRI/SIMILAR INERT MATERIAL.
SWEEP/SCRAPE UP & CONTAINERIZE. RINSE AREA THOROUGHLY W/WATER.
WEAR/USE APPROPRIATE PROTECTIVE EQUIPMENT.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY ADEQUATELY
VENTILATED AREA. PRODUCT RESIDUE MAY REMAIN ON/IN EMPTY CONTAINERS.
ALL PRECAUTIONARY MEASURES SHOULD BE TAKEN.
Other Precautions:AVOID CONTACT OF UNDILUTED/DILUTED PRODUCT
W/SKIN/EYES/CLOTHING. AVOID BREATHING SPRAY MIST. KEEP OUT OF REACH
OF CHILDREN.
* Physical/Chemical Properties *
Spec Gravity:1.1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR SOLUTION W/MILD ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, MURIATIC ACID
Hazardous Decomposition Products:PRODUCES NORMAL PRODUCTS OF COMBUSTION
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL OF REGULATED QUANTITIES SHOULD BE
NEUTRALIZATION AT A PERMITTED FACILITY IAW/FEDERAL, STATE & LOCAL
REGULATIONS REGARDING CORROSIVE WASTE. WASTE FROM NORMAL PRODUCT
USE MAY BE SEWERED TO A PU BLIC-OWNED TREATMENT WORKS
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED IF TWA LIMITS ARE EXCEEDED.
Ventilation:SUFFICIENT TO KEEP BELOW TWA LIMITS.
Other Protective Equipment:SUFFICIENT TO PREVENT CONTACT.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:DICHLOROMETHANE (METHYLENE CHLORIDE) (SUSP HUMAN CARC BY
Ingred Name:ETHANOL (ETHYL ALCOHOL), TECSOL, ALCOHOL, SYNASOL
Ingred Name:TRIETHYL PHOSPHITE
Fraction by Wt: 2-5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION, BURNS. SKIN:
IRRITATION, BURNS.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:IRRITATION, BURNS, INFLAMMATION, DIZZINESS,
FATIGUE, HEADACHE, NAUSEA, VOMITING.
* First Aid Measures *
INHALATION: REMOVE TO FRESH AIR. INGESTION: GIVE LARGE QUANTITIES
OF WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:WATER FOG
Fire Fighting Procedures:SCBA & FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:FLAMMABLE VAPOR/AIR MIXTURE POSSIBLE.
* Accidental Release Measures *
Spill Release Procedures:MOP, WIPE/SOAK UP IMMEDIATELY W/SUITABLE
ABSORBENT. PLACE IN A SUITABLE CONTAINER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, DRY WELL VENTILATED
* Physical/Chemical Properties *
Vapor Density:2.9
Spec Gravity:1.2
Evaporation Rate & Reference:(BU AC =1): >1
Solubility in Water:SLIGHT
Appearance and Odor:HAZY, LIGHT COLORED LIQUID W/SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Hazardous Decomposition Products:OPEN FLAMES: THERMAL DEGRADATION
GIVING OFF CHLORINE & HYDROGEN CHLORIDE.
* Disposal Considerations *
Waste Disposal Methods:SEND TO AN EPA APPROVED WASTE DISPOSAL FACILITY.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NO SPECIAL RESPIRATOR PROTECTION IS NORMALLY
REQUIRED. HOWEVER, IF OPERATING CONDITIONS CREATE HIGH AIRBORNE
CONCENTRATIONS, THE USE OF A NIOSH/MSHA APPROVED RESPIRATOR IS
RECOMMENDED.
Ventilation:USE ADEQUATE VENTILATION TO KEEP THE AIRBORNE
CONCENTRATIONS OF THIS MATERIAL BELOW THE RECOMMENDED EXPOSURE
STANDARD.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC:CONSULT MEDICAL PERSONNEL BEFORE INDUCING VOMITING. IF
MEDICL ADVICE CANNOT BE OBTAINED, THEN TAKE THE PESON & PRODUCT
CNTNR TO THE NEAREST MED EMERGENCY TREATMENT CENTER OR HOSPITAL. S
PILL PROC: SURF WATER/GROUNDWATER. CLEAN UP SML SPILLS USING APPROP
TECHNIQUES SUCH AS SORBENT MATLS OR PUMPING.(ING 4)
* Product Identification *
CAGE:0AHD1
CAGE:0AHD1
* Composition/Information on Ingredients *
Ingred Name:BASE OIL
Other REC Limits:NONE RECOMMENDED
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BASE OIL
Other REC Limits:NONE RECOMMENDED
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:LUBRICATING OIL BASE STOCK
Ingred Name:ADDITIVES
Ingred Name:CHLORINATED PARAFFIN
Fraction by Wt: < 1%
Ingred Name:SUPP DATE: WHERE FEASIBLE AND APPROPRIATE, REMOVE
CONTAMINATED SOIL. FOLLOW PRESCRIBED PROCEDURES FOR REPORTING &(ING
5)
Ingred Name:ING 4: RESPONDING TO LARGER RELEASES.
Ingred Name:MATLS TO AVOID: INCOMPLETE COMBUSTION CAN PRODUCE CARBON
MONOXIDE.
Ingred Name:BASE OIL
Other REC Limits:NONE RECOMMENDED
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BASE OIL
Other REC Limits:NONE RECOMMENDED
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BASE OIL
Other REC Limits:NONE RECOMMENDED
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BASE OIL
Other REC Limits:NONE RECOMMENDED
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BASE OIL
Other REC Limits:NONE RECOMMENDED
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BASE OIL
Other REC Limits:NONE RECOMMENDED
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BASE OIL
Other REC Limits:NONE RECOMMENDED
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BASE OIL
Other REC Limits:NONE RECOMMENDED
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BASE OIL
Other REC Limits:NONE RECOMMENDED
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE/SKIN: THIS SUBSTANCE IS NOT
EXPECTED TO CAUSE PROLONGED OR SIGNIFICANT EYE/SKIN IRRIT. THIS
HAZARD EVALUATION IS BASED ON THE DATA FROM SIMILAR MATLS.
DERMAL/RESP/INHAL/INGEST TOX: THE STYSTEMIC T OX OF THIS SUBSTANCE
HAS NOT BEEN DETERMINED. HOWEVER, IT SHOULD BE PRACTICALLY
NON-TOXIC TO INTERNAL (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: ORGANS IF IT GETS ON SKIN, INHALED,
SWALLOWED. THIS HAZ EVALUATION IS BASED ON DATA FROM SIMILAR MATLS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:EYES:NO FIRST AID PROC ARE REQUIRED. HOWEVER, AS A PRECAUTION
WORN. SKIN: NO FIRST AID PROC REQUIRED. AS A PREC, WASH SKIN THORO
W/SOA P & WATER. REMOVE & WASH CONTAMINATED CLTHG. INHAL:REMOVE TO
FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP). INGEST: GIVE
* Fire Fighting Measures *
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:FOR FIRES INVOLVING THIS MATL, DO NOT ENTER
ANY ENCLOSED OR CONFINED FIRE SPACE WITHOUT NIOSH/MSHA APPROVED
SCBA & FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:THIS MATL IS NOT EXPECTED TO PRESENT ANY
ENVIRONMENTAL PROLEMS OTHER THAN THOSE ASSOC W/OIL SPILLS. STOP THE
SOURCE OF THE LEAK OR RELEASE. CLEAN UP RELEASES AS SOON AS
POSSIBLE. CONTAIN LIQ TO PREVEN T FURTHER CONTAMINATION OF SOIL,
(SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DO NOT WELD/HEAT/DRILL CNTNR. RESIDUE
MAY IGNITE W/EXPLO VIOLENCE IF HEATED SUFFICIENTLY. CAUTION! DO NOT
USE PRESSURE TO EMPTY DRUM/EXPLO MAY RSLT.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:V6
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR, PALE YELLOW LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
MAY REACT WITH STRONG OXIDIZING AGENTS, SUCH AS CHLORATES, NITRATES,
PEROXIDES, ETC.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NORMAL COMBUSTION FORMS CARBON DIOXIDE
& WATER VAPOR; INCOMPLETE COMBUSTION CAN PRODUCE CARBON MONOXIDE.
(ING 6)
* Disposal Considerations *
Waste Disposal Methods:PLACE CONTAMINATED MATL IN DISPOSABLE CNTNRS &
DISPOSE OF IN A MANNER CONSISTENT W/APPLICABLE REGULATIONS. CONTACT
LOCAL ENVIROMENTAL OR HEALTH AUTHORITIES FOR APPRVD DISPOSAL OF
THIS MATL. DIPSOSAL M UST BE I/A/W FEDERAL, STATE & LOCAL REGS .
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:UREA
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE IRRITATING TO SKIN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . SKIN:WASH IMMEDIATELY
W/PLENTY OF WATER. EYES:RINSE IMMEDIATELY W/PLENTY OF WATER FOR AT
* Fire Fighting Measures *
Flash Point Method:OC
Flash Point:NOT PERTINENT
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:COLLECT IN SUITABLE RECEPTACLES. WASH
REMAINDER AWAY W/COPIOUS QUANTITIES OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:PROTECT FROM MOISTURE.
Other Precautions:HYGROSCOPIC.
* Physical/Chemical Properties *
HCC:N1
Boiling Pt:B.P. Text:SUPP DATA
pH:SUPDAT
Appearance and Odor:SOLID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS LIKE NANO*2, OCL, CRO*2CL*2, PCL*5.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:ON HEATING IT DECOMPOSES TO BIURET,
NH*3, CYANURIC ACID.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . SMALL AMOUNTS MAY BE WASHED DOWN THE DRAIN W/EXCESS
WATER. USE AS FERTILIZER.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
NECESSARY.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
AIRBORNE CONCENTRATIONS BELOW PELS.
Other Protective Equipment:ANSI APPROVED EYE WASH FOUNTAIN & DELUGE
SHOWER . WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN
CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING & WASH BEFORE REUSE.
Supplemental Safety and Health
EXPLO HAZ:GENERATED BY THERMAL DECOMP/COMBUST. FLAMM LIQ. CAN RELS VAPS
THAT FORM EXPLO MIXTS AT TEMPS ABOVE FLASHPOINT. SPILL PROC:COMBUST
MATL SUCH AS EARTH, SAND/VERMICULITE. MATLS TO AVOID:SODIUM
HYPOCHLORITE), ACTIVE METALS (SUCH AS POTASSIUM & MAGNESIUM).
SUBSTANCE IS ALSO (ING 2)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SUPDAT:INCOMPAT W/SPECIFIC CHEMS INCL:ACETYL BROMIDE, ALKYL
ALUMINUM SALTS, BERYLLIUM DIHYDRIDE, CARBON (ING 3)
Ingred Name:ING 2:TETRACHLORIDE + METALS, CHLOROFORM + HEAT, CHLOROFORM
+ SODIUM HYDROXIDE, CYANURIC CHLORIDE, DIETHYL ZINC, (ING 4)
Ingred Name:ING 3:NITRIC ACID & POTASSIUM TERTBUTOXIDE. PLEASE REFER TO
NFPA FIRE PROTECTION GUIDE FOR ALL SPECIFICS.
Ingred Name:EFTS OF OVEREXP:CHRONIC:PRLNG/RPTD SKIN CONT MAY CAUSE
DERM. CHRONIC INHAL & INGEST MAY CAUSE EFTS SIMILAR TO (ING 6)
Ingred Name:ING 5:THOSE OF ACUTE INHAL & INGEST. TARGET ORGS:KIDNEYS,
CNS, LIVER, EYES. TOX INFO:EFTS ON NEWBORN:BEHAVIORAL; (ING 7)
Ingred Name:ING 6:EMBRYO/FETUS:FETOTOXICITY; SPECIFIC DEVEL
ABNORMS:CVS, MUSCULOSKELETAL, UROGENITAL; PATERNAL EFTS: (ING 8)
Ingred Name:ING 7:SPERMATOGENESIS; DNA DAMAGE; DNA INHIBITOR.
Ingred Name:FIRST AID PROC:TSP OF SYRUP OF IPECAC. INHAL:GET MED AID
Ingred Name:ING 9:BRTHG, GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE OXYG.
Ingred Name:OTHER PREC:STORAGE AREA. HARMFUL IF INHALED. POISON-CANNOT
ADVICE IMMED (SHOW LBL WHERE POSS). KEEP CNTNR TIGHTLY CLOSED.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE:CAUSES MOD IRRIT. VAPS MAY
CAUSE IRRIT. MAY CAUSE PAINFUL SENSIT TO LIGHT. SKIN:MAY CAUSE
IRRIT. MAY BE ABSORBED IN HARMFUL AMTS. INGEST:MAY CAUSE IRRIT OF
DIGEST TRACT. MAY CAUSE CNS DEPRES S, CHARACT BY EXCITEMENT,
FOLLOWED BY HDCH, DIZZ, DROW & NAUS. ADVANCED STAGES MAY CAUSE
COLLAPSE, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:UNCON, COMA & POSS DEATH DUE TO RESP
FAILURE. MAY CAUSE KIDNEY FAILURE. INHAL:MAY CAUSE RESP TRACT
IRRIT. MAY CAUSE LIVER & KIDNEY DMG. MAY CAUSE ADVERSE CNS EFTS
INCL HDCH, CONVLS & POSS DEA TH. MAY CAUSE VISUAL IMPAIRMENT & POSS
PERM BLINDNESS. MAY CAUSE EFTS SIMILAR TO THOSE DESCRIBED FOR
INGEST. (ING 5)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. DO NOT ALLOW VICTIM
TO RUB/KEEP EYES CLSD. SKIN:FLUSH W/PLENTY OF SOAP & WATER FOR AT
IRRIT DEVELS/PERSISTS. INGEST:IF VICTIM IS CONSCIOUS & ALERT, GIVE
2-4 CUPFULS OF MILK/WATER. GET MED AID IMMED. INDUCE VOMIT BY
GIVING 1 (ING 9)
* Fire Fighting Measures *
Lower Limits:6%
Extinguishing Media:FOR SMALL FIRES, USE DRY CHEMICAL, CARBON DIOXIDE,
WATER SPRAY OR ALCOHOL-RESISTANT FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . USE WATER TO COOL FIRE-EXPOSED CONTAINERS. WATER MAY BE
INEFFECTIVE.
Unusual Fire/Explosion Hazard:CNTNRS CAN BUILD UP PRESS IF EXPOS TO
HEAT &/OR FIRE. VAPS CAN TRAVEL TO SOURCE OF IGNIT & FLASH BACK.
DURING FIRE, IRRIT & HIGHLY TOX GASES MAY BE (SUPP DATA)
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PPE AS INDICATED IN EXPOS CONTROLS,
PERSONAL PROT SECTION. SCOOP UP W/NONSPARKING TOOL, THEN PLACE INTO
SUITABLE CNTNR FOR DISP. USE WATER SPRAY TO DISPERSE GAS/VAP.
REMOVE ALL SOURCES OF I GNIT. ABSORB SPILL USING ABSORB, NON- (SUPP
DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:USE W/ADEQUATE VENT. EMPTY CONTAINERS
RETAIN PRODUCT RESIDUE (LIQUID &/OR VAPOR) & CAN BE DANGEROUS. DO
NOT GET ON SKIN/IN EYES. DO NOT INGEST/INHALE.
Other Precautions:DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL,
GRIND/EXPOSE EMPTY CNTNRS TO HEAT, SPKS/OPEN FLAMES. KEEP AWAY FROM
SOURCES OF IGNIT-NO SMOKING. STORE IN COOL, DRY, WELL-VENTED AREA
* Physical/Chemical Properties *
Vapor Density:1.1
Evaporation Rate & Reference:5.2 (ETHER=1)
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID; SLIGHT ALCOHOL-LIKE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDANTS (SUCH AS BARIUM PERCHLORATE, BROMINE, CHLORINE, HYDROGEN
PEROXIDE, LEAD PERCHLORATE, PERCHLORIC ACID, (SUPDAT)
Stability Condition to Avoid:HIGH TEMPERATURES, INCOMPATIBLE MATERIALS,
IGNITION SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
FORMALDEHYDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT W/FEDERAL,
WASTE). THIS MATERIAL IS BANNED FROM LAND DISPOSAL ACCORDING TO
RCRA.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:CHEMICAL FUME HOOD.
Other Protective Equipment:LAB COAT. HAVE IMMEDIATE AVAILABILITY OF AN
EYE WASH IN CASE OF EMERGENCY.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Product ID:CUSTOM PLASMA STANDARD, PLS9-2Y
* Composition/Information on Ingredients *
Ingred Name:AMMONIUM SULFATE (2:1); (AMMONIUM SULFATE (SOLUTION);
Fraction by Wt: SEE ING
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS SOLUTION MAY BE HARMFUL IF
INHALED, INGESTED, OR CONTACTED WITH THE SKIN OR EYES. AMMONIUM
SULFATE MAY BE HARMFUL TO THE RESPIRATORY TRACT IF INHALED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
LIFTING UPPER AND LOWER EYELIDS. SKIN: REMOVE CONTAMINATED
THORO BEFORE REUSE . INHAL: MOVE TO FRESH AIR. INGEST: DO NOT
INDUCE VOMITING. GET LARGE QUANTITIES OF WATER OR MILK. IF
IRRITATION CONTINUES, GET MEDICAL ATTENTION IMMEDIATELY.
* Fire Fighting Measures *
Extinguishing Media:APPROPRIATE TO SURROUNDING FIRE CONDITIONS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA. WIPE UP AND PUT INTO A SEALED
CONTAINER FOR PROPER DISPOSAL. WASH SPILL SITE OFF WITH WATER AFTER
MATERIAL PICK-UP IS COMPLETE. WEAR CHEMICAL RESISTANT GLASSES,
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:STORE AT ROOM TEMPERATURES. KEEP
TIGHTLY SEALED WHEN NOT IN USE.
Other Precautions:
* Physical/Chemical Properties *
HCC:T6
Spec Gravity:1
Solubility in Water:SOLUBLE IN WATER
Appearance and Odor:TRANSPARENT SOLUTION WITHOUT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACIDS.
Stability Condition to Avoid:
Hazardous Decomposition Products:WILL RELEASE TOXIC FUMES OF AMMONIA.
* Disposal Considerations *
Waste Disposal Methods:CONTACT LOCAL HAZARDOUS OR CHEMICAL WASTE
DISPOSAL AGENCY FOR REGULATIONS. DISPOSAL MUST BE IN ACCORDANCE
WITH FEDERAL, STATE AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED. NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Other Protective Equipment:NONE
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR TRADE NAME/PART NO: TABLETS, POWDER AND CAPSULES.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SILVER (SARA III)
ACGIH TLV:0.1 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TIN
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:COPPER (SARA III)
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2MG/M3 FUME
Ingred Name:ZINC (SARA III)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE AND CHRONIC: EYES: MAY CAUSE
IRRITATION UPON CONTACT. SKIN: AVOID REPEATED CONTACT WITH SKIN,
CHRONIC EXPOSURE MAY CAUSE ARGYRIA (GRAYISH-BLUE PIGMENTATION OF
THE SKIN). NO KNOWN SERIOUS TOXIC S YMPTOMS HAVE BEEN NOTED
FOLLOWING EXPOSURE. INHAL: (POWDER ONLY) INHAL OF ALLOY POWDER MAY
CAUSE IRRIT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: OF MUCOUS MEMBRANES. INGEST:
INGESTION OF ALLOY MAY CAUSE GI TRACT IRRITATION, NAUSEA OR
DIARRHEA.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:EYES: IMMEDIATELY FLUSH EYES WITH COPIOUS QTYS OF WATER FOR
PERSISTS. SKIN: WASH THOROUGHLY WITH SOAP AND WATER. INHAL: GENTLY
BLOW NOSE AND IRRIGATE WITH CLEAN WATER. CONSULT PHYSICIAN IF
IRRITATION PERSISTS. INGEST: IF SWALLOWED, SEEK MEDICAL ATTENTION.
* Fire Fighting Measures *
Extinguishing Media:EXTINGUISHING MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
* Accidental Release Measures *
Spill Release Procedures:PROVIDE EXHAUST VENTILATION WHEN POSSIBLE.
CAREFULLY SWEEP OR VACUUM INTO ACCEPTABLE WASTE CONTAINER. AVOID
GENERATING AIRBORNE DUST.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY ENVIRONMENT.
AVOID CONTACT OR GENERATION OF DUST.
Other Precautions:NONE
* Physical/Chemical Properties *
HCC:N1
Spec Gravity:8.0
Appearance and Odor:A METALLIC GRAYISH TABLET OR FREE FLOWING, METALLIC
GRAY POWDER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACETYLENE, HYDROGEN PEROXIDE, OR ETHYLENEIMINE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:THE PRODUCT OR INDIVIDUAL COMPONENTS MAY BE
SALAVAGED OR RECLAIMED FOR REUSE. WASTE MATERIAL MAY BE DISPOSED OF
ACCORDING TO LOCAL, STATE AND FEDERAL REGULATIONS .
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:RESPIRATOR RECOMM/APPROVED IN ISOCYANATE
CONTAINING ENVIRONMENTS MAY BE NECESSARY. USE AIR PURIFYING
RSPRTR/POSITIVE PRESSURE SUPPLIED AIR RSPRTR APPROPRIATE FOR
ISOCYANATE CONCENTRATIONS. SEE ORIGINA L MSDS ON FILE FOR FURTHER
INFORMATION.
Ventilation:EXHAUST VENT SUFF TO KEEP AIRBORNE CONC OF HDI AND
POLYISOCYANATE BELOW TLV. EXHAUST AIR MAY NEED TO BE CLEANED.
Other Protective Equipment:COVER AS MUCH SKIN AS POSSIBLE W/APPROPRIATE
CLOTHES. IF SKIN CREAMS USED, KEEP AREA PROTECTED BY ONLY CREAM TO
MINIMUM.
Work Hygienic Practices:PRECAUTIONS TO AVOID SKIN/EYE CONTACT/BREATHE
VAPOR. WASH CONTAM CLOTHING BEFORE REUSE. EYEWASH & SFTY SHOWERS
NEEDED.
Supplemental Safety and Health
KEY1:F4. KIT CONSISTS OF TWO PARTS. PART ONE HAS PNI A, PART TWO HAS
PNI B, SAME NSN. FOR PREVIOUS FORMULATION, SEE PNI B, SAME NSN.
* Product Identification *
Kit Part:Y
Preparer's Name:MICHAEL J LICHATOWICH
* Composition/Information on Ingredients *
Ingred Name:HOMOPOLYMER OF HDI
Other REC Limits:NONE SPECIFIED
Ingred Name:HEXAMETHYLENE DIISOCYANATE *(RESIDUAL MONOMER CONTENT
LESS THAN 0.5% BASED ON RESIN SOLIDS AT TIME OF MFR.**
Fraction by Wt: *
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:**AFTER 3-6 MO STORAGE, THE FREE MONOMER CONTENT MAY RISE
Other REC Limits:NONE SPECIFIED
Other REC Limits:NONE SPECIFIED
Other REC Limits:NONE SPECIFIED
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: IRRIT, REDUCED LUNG FUNCTION
(BREATHING OBSTRUCTION),LUNG DAMAGE, BRONCHITIS, BRONCHIAL SPASM,
PULMONARY EDEMA. CHEMICAL/HYPERSENSITIVE PNEUMONITIS. EYE, NOSE,
THROAT IRRIT. HIGH CONC CAN CAUSE DEATH. SOME INDIVIDUALS MAY
DEVELOP ISOCYANATE SENSITIZATION (LATER REACT W/EXPOS BELOW TLV).
MORE INFORMATION ON FILE.
Effects of Overexposure:BURNING SENSATION (NOSE, THROAT, LUNGS), RUNNY
NOSE, SORE THROAT, COUGHING, WHEEZING, ASTHMATIC ATTACK, LUNG
SENSITIVITY, CHEST DISCOMFORT, SHORTNESS OF BREATH, FEVER, CHILLS.
DRYNESS (THROAT), TIGHTN ESS (CHEST). HEADACHE, NAUSEA, NARCOSIS,
FATIGUE, LOSS OF APPETITE. REDNESS, RASH, SWELLING, SCALING,
BLISTERING. ****
Medical Cond Aggravated by Exposure:ASTHMA & OTHER RESPIRATORY
DISORDERS (BRONCHITIS, EMPHYSEMA, HYPERREACTIVITY), SKIN ALLERGIES,
ECZEMA. ****LOSS OF
COORDINATION, LOSS OF INTELLECTUAL ABILITY.
* First Aid Measures *
First Aid:INHAL:MOVE TO FRESH AIR. ADMIN OXYGEN/ARTIF RESP. CALL DR.
ASTHMATIC SYMPTOMS? TREAT SYMPTOMATICALLY. CALL DR. SKIN:REMOV
CONTAM CLOTH. WASH W/SOAP & WTR. SEVERE EXPOS, REMOVE CLOTH, GET
UNDER SAFETY SHOWER. CALL DR. LESSER EXPOS-CALL DR, IF IRRIT
VOMIT. 1-2 CUPS MILK/WATER. NOTHING BY MOUTH UNCONSCIOUS/CONVULSING
PERSON. CALL DR.
* Fire Fighting Measures *
Flash Point Method:SCC
Lower Limits:1.0
Upper Limits:7.6
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:FULL EMERG EQUIP (SCBA & FULL PROTECT CLOTH).
DURING FIRE, HDI & OTHER TOXIC GASSES MAY BE GENERATED. ISOLATE
FROM IGNIT SOURCE. CLSD CNTNR MAY EXPLODE W/HEAT.*
Unusual Fire/Explosion Hazard:*CLSD CNTNR MAY BURST WHEN CONTAM W/WATER
CREATING CO2. SOLVENT VAPOR HEAVIER THAN AIR, MAY TRAVEL ALONG
GROUND TO IGNITION SOURCE & FLASHBACK TO VAPOR SOURCE.
* Accidental Release Measures *
Spill Release Procedures:EVAC PEOPLE. REMOVE IGNIT SOURCES. VENT.
DIKE/STOP SPILL. NOTIFY AUTHORITIES. COVER SPILL W/ABSORB/DECONTAM
RECOMMENDED.
Neutralizing Agent:DECONTAM SOLUTIONS: NONIONIC SURFACTANT TERGITOL
*Handling and Storage *
FROM IGNITION SOURCE/HEAT. GRND CNTNRS DURING STORAGE/TRANSFER.
STORE IN CLSD CNTNRS. DO NOT RESEAL IF CONTAM.
Other Precautions:AVOID CONTACT W/SKIN & EYES. USE OF POS PRESSURE AIR
SUPPLIED RESP MAY BE NECESSARY FOR MIXING OR BRUSH APPLICATIONS.
SEE ADDITIONAL INFO ON FILE. FOLLOW LABEL INSTRUCT.
* Physical/Chemical Properties *
HCC:F2
Vapor Density:> AIR
Evaporation Rate & Reference:SLOWER ETHER (BU AC=1)
Solubility in Water:INSOL/REACTS W/WATER
Appearance and Odor:CLEAR TO PALE YELLOW LIQUID/SOLVENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
WATER, AMINES, STRONG BASES, ALCOHOLS, METAL COMPOUNDS, AND SURFACE
ACTIVE MATERIALS.
Stability Condition to Avoid:MOISTURE, HIGH TEMPERATURES, SHOCK FROM
DROPPING.
Hazardous Decomposition Products:BY HIGH HEAT AND FIRE: CARBON DIOXIDE,
CARBON MONOXIDE, OXIDES OF NITROGEN, TRACES OF HCN AND HDI.
Conditions to Avoid Polymerization:MAY OCCUR IF IN CONTACT W/MOISTURE
OR OTHER MATERIALS WHICH REACT W/ISOCYANATES. MAY OCCUR AT
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORD W/ FEDERAL, STATE & LOCAL
ENVIRONMNTL CNTRL REGS. INCINERATION PREFERRED. IGNITABLE HAZARDOUS
WASTE (PROD RESIDUE/FLAMMABLE SOLVENT VAPOR). DECONTAMINATE
CONTAINERS PRIOR TO DISPOSAL . DON'T HEAT/CUT ON OR NEAR EMPTY
CONTAINERS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED RESPIRATOR.
Ventilation:RECOMMENDED WHEN MIXING INDOORS.
Other Protective Equipment:CLOTHING THAT COVER ARMS AND LEGS. EMERGENCY
EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC:BY NIOSH. PROTECT EYES FROM DUST. PRESENCE OF TYPE S
HYDRATED LIME IN FIRE DOES NOT HINDER USE OF ANY STD EXTING MEDIUM.
* Product Identification *
Product ID:MONOLITE FAST PATCH
* Composition/Information on Ingredients *
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (CRYSTALLINE SILICA)
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:CALCIUM HYDROXIDE
ACGIH TLV:5 MG/M3
Ingred Name:SILICATE, PORTLAND CEMENT; (PORTLAND CEMENT)
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (MAGNESIUM
SILICATE HYDRATE)
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:CADMIUM AND CADMIUM COMPOUNDS; (CADMIUM LITHOPONE PRIMROSE)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:IN PRESENCE OF MOISTURE, CONTACT
WITH SKIN AND EYES COULD CAUSE IRRITATION & POSSIBLE SEVERE
CORROSION DAMAGE. SIGNS & SYMPTOMS OF EXPOSURE:IRRITATION OF THE
EYES & SKIN. INHALATION MAY CAUSE CO UGHING & SNEEZING.
CHRONIC:REPEATED OR PROLONGED SKIN CONTACT MAY CAUSE DERMATITIS &
CHEMICAL BURNS. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC
ANNUAL RPT ON (SUPDAT)
Effects of Overexposure:HLTH HAZ:CONSTANT EXPOSURE TO DUST COULD
CONTRIBUTE TO SILICOSIS.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN SENSITIVITIES OR
DERMATITIS. CRYSTALLINE FREE SILICA DUST ABOVE THE TLV MAY CAUSE
SCARRING OF LUNGS AND SHORTNESS OF BREATH.
* First Aid Measures *
CONTACTING A PHYSICIAN. SKIN:WASH W/PLENTY OF WATER AND SOAP.
INHAL:RINSE THROAT WITH WATER. INGEST:DRINK LOTS OF WATER.
RECOMMEND CONTACTIN G A PHYSICIAN.
* Fire Fighting Measures *
Extinguishing Media:EXTINGUISH FIRES WITH A WATER SPRAY OR
MULTI-PURPOSE DRY CHEMICAL.
Fire Fighting Procedures:DOLOMITIC HYDRATE LIME DEHYDRATES TO MAGNESIUM
UPPER TEMPS PREVAIL, WEAR SCBA APPRVD(SUPDAT)
Unusual Fire/Explosion Hazard:NOT APPLICABLE.
* Accidental Release Measures *
Spill Release Procedures:AVOID BREATHING DUST WHILE CLEANING UP DRY
MATERIAL. IF MIXED MATERIAL IS RELEASED OR SPILLED, RINSE AREA
THOROUGHLY WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL DRY PLACE. HANDLE AS
NUISANCE DUST.
Other Precautions:WORKER SHOULD WEAR DUST RESPIRATORS IF MATERIAL IS
BECOMING AIRBORNE AND CAUSING IRRITATION.
* Physical/Chemical Properties *
Solubility in Water:SLIGHT
Appearance and Odor:LOOKS LIKE COLORED SAND DEPENDING ON PIGMENT.
EARTHY ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NITROPARAFEIN MALEIC AMAVORIDE/PHOSPHOROUS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NOT APPLICABLE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS .
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, WEAR A PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESPIRATOR APPROVED BY NIOSH FOR PROTECTION
AGAINST MATERIALS IN THE INGREDIENTS SECTION. WHEN SANDING OR
ABRADING THE DRIED FILM, WEAR A DUST/MIST RESPIRATOR APPROVED BY
NIOSH FOR DUST WHICH MAY BE GENERATED (HYGIENE PRACT)
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF THE
EXPOSURE TO MATERIALS IN INGREDIENTS SECTION IS MAINTAINED BELOW
APPLICABLE (OTHER PROT EQUIP)
(WORK HYGIENE)
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . VENTILATION (CONT'D): EXPOSURE LIMITS. REFER TO
Work Hygienic Practices:LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
WASH HANDS AFTER USING. RESPIRATORY PROT (CONT'D): FROM THIS
PRODUCT, UNDERLYING PAINT, OR THE ABRASIVE. EYE PROT: SPECTACLES
WITH UNPERFORATED SIDESHIELDS.
Supplemental Safety and Health
THESE COATINGS MAY CONTAIN MATERIALS CLASSIFIED AS NUISANCE
PARTICULATES (LISTED "AS DUST" IN INGREDIENTS SECTION) WHICH MAY
BE PRESENT AT HAZARDOUS LEVELS ONLY DURING SANDING OR ABRADING OF
THE DRIE D FILM. IF NO SPECIFIC DUSTS ARE LISTED IN INGREDIENTS
SECTION, THE APPLICABLE LIMITS FOR NUISANCE DUSTS (TOX INFO)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ETHYLENE GLYCOL. (VAPOR PRESSURE: 0.1 MMHG.)
Minumum % Wt:1.
Maxumum % Wt:6.
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TITANIUM DIOXIDE
Minumum % Wt:9.
OSHA STEL:5 MG/M3 (RESP FRAC)
Ingred Name:CARBON BLACK
Minumum % Wt:0.
Maxumum % Wt:2.
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:WATER
Ingred Name:CRISTOBALITE
Minumum % Wt:0.
Maxumum % Wt:.1
OSHA PEL:SEE TABLE Z-3
Ingred Name:2-(2-BUTOXYETHOXY)ETHANOL. (VAPOR PRESSURE: 0.1 MMHG)
Minumum % Wt:0.
Maxumum % Wt:2.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ROUTES OF EXPOSURE: EXPOSURE MAY BE BY
INHALATION AND/OR SKIN OR EYE CONTACT, DEPENDING ON CONDITIONS OF
USE. TO MINIMIZE EXPOSURE, FOLLOW RECOMMENDATIONS FOR PROPER USE,
VENTILATION, & PERSONAL PROTE CTIVE EQUIPMENT. ACUTE: IRRITATION OF
EYES, SKIN & UPPER RESPIRATORY SYSTEM. IN A CONFINED AREA VAPORS IN
HIGH CONCENTRATION MAY CAUSE HEADACHE, NAUSEA OR DIZZINESS.
CHRONIC: CRYSTALLINE SILICA (QUART Z, CRISTOBALITE) IS LISTED BY
IARC & NTP. LONG TERM EXPOSURE TO HIGH LEVELS OF SILICA DUST, WHICH
CAN OCCUR ONLY WHEN SANDING OR ABRADING THE DRY FILM, MAY CAUSE
LUNG DAMAGE (SILICOSIS) & POSSIBLY CAN CER. (EFFECTS OF
OVEREXPOSURE)
9TH REPORT, KNOWN TO BE HUMAN CARCINOGEN; SILICA, CRYSTALLINE
(INHALED IN THE FORM OF QUARTZ OR CRISTOBALITE FROM OCCUPATION
Effects of Overexposure:HEALTH HAZARDS (CONT'D): CARBON BLACK IS
CLASSIFIED BY IARC AS POSSIBLY CARCINOGENIC TO HUMANS (GROUP 2B)
BASED ON EXPERIMENTAL ANIMAL DATA, HOWEVER, THERE IS INSUFFICIENT
EVIDENCE IN HUMANS FOR ITS C ARCINOGENICITY. ETHYLENE GLYCOL IS
CONSIDERED AN ANIMAL TERATOGEN. IT HAS BEEN SHOWN TO CAUSE BIRTH
DEFECTS IN RATS AND MICE AT HIGH DOSES WHEN GIVEN IN DRINKING WATER
OR BY GAVAGE. THERE IS NO EVIDEN CE TO INDICATE IT CAUSES BIRTH
DEFECTS IN HUMANS.PROLONGED OVEREXPOSURE TO SOLVENT INGREDIENTS
MAY CAUSE ADVERSE EFFCTS TO LIVER & URINARY SYSTEMS. RATS EXPOSED
TO TITANIUM DUST (TOXICOLOGICAL)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
* First Aid Measures *
First Aid:IF INHALED: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE
BREATHING. KEEP WARM AND QUIET. IF ON SKIN: WASH AFFECTED AREA
THOROUGHLY WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING AND
LAUNDER BEFORE RE USE. IF IN EYES: FLUSH EYES WITH LARGE AMOUNTS
MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point:NONE
Lower Limits:N.AP.
Upper Limits:N.AP.
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL FOAM.
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT INCLUDING NIOSH
APPROVED SELF CONTAINED BREATHING APPARATUS SHOULD BE USED. WATER
SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE. WATER MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT
PRESSURE BUILD-UP & POSSIBLE AUTOIGNITION OR EXPLOSION WHEN EXPOSED
TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO THE
BUILD-UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT. FLAMMABILITY
CLASSIFICATION: NOT APPLICABLE.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
*Handling and Storage *
Handling and Storage Precautions:DOL STORAGE CATEGORY: NOT APPLICABLE.
KEEP CONTAINER CLOSED WHEN NOT IN USE. TRANSFER ONLY TO APPROVED
CONTAINERS WITH COMPLETE AND APPROPRIATE LABELING. DO NOT TAKE
INTERNALLY. KEEP OUT OF THE REACH OF CHILDREN. USE ONLY WITH
ADEQUATE VENTILATION. AVOID BREATHING VAPOR AND SPRAY (OTHER
PRECAUTIONS)
Other Precautions:HANDLING/STORAGE (CONT'D): MIST. AVOID CONTACT WITH
SKIN AND EYES. WASH HANDS AFTER USING.
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:N.A.
Vapor Density:> THAN AIR
pH:9.0 - 9.5
Evaporation Rate & Reference:SLOWER THAN ETHER.
Solubility in Water:N.A.
Appearance and Odor:NOT SPECIFIED BY MANUFACTURER .
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN. PHOTOCHEMICALLY REACTIVE: NO.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE.
* Toxicological Information*
Toxicological Information:N/P. SIGNS/SYMPTOMS OF OVEREXPOSURE (CONT'D):
ARE NOT ATTAINABLE IN THE WORKPLACE. REDNESS AND ITCHING OR BURNING
SENSATION MAY INDICA TE EYE OR EXCESSIVE SKIN EXPOSURE.
MG/M3 (RESPIRABLE FRACTION).
* Ecological Information *
Ecological:N/P.
* Disposal Considerations *
Waste Disposal Methods:WASTE FROM THESE PRODUCTS IS NOT HAZARDOUS AS
CONTAINER. DISPOSEOF IN ACCORDANCE WITH FEDERAL, STATE, AND LOCAL
REGULATIONS REGARDING POLLUTION.
* MSDS Transport Information *
Transport Information:N/P.
* Regulatory Information *
SARA Title III Information:INGREDIENTS SUBJECT OT THE REPORTING
REQUIREMENTS OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT
ETHYLENE GLYCOL.
Federal Regulatory Information:TSCA CERTIFICATION: ALL CHEMICALS IN
THESE PRODUCTS ARE LISTED, OR ARE EXEMPT FROM LISTING, ON THE TSCA
INVENTORY.
State Regulatory Information:THIS PRODUCT CONTAINS CHEMICALS KNOWN TO
THE STATE OF CALIFORNIA TO CAUSE CANCER.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NORMALLY REQUIRED. IF WORKING IN CONFINED
AREAS, IF EXCESSIVE MISTING IS EXPECTED OR IF EXPOSURE MAY OR DOES
EXCEED RECOMMENDED PERMISSIBLE EXPOSURE LIMITS (PEL), WEAR
NIOSH-APPROVED ORGANIC VAPO R RESPIRATOR.
Ventilation:GENERAL ROOM VENTILATION SHOULD BE SUFFICIENT.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
SHOES.
Supplemental Safety and Health
DIFFERENT FORMULA AND/OR CONCENTRATIONS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SOLVENT REFINED LIGHT PARAFFINIC PETROLEUM
DISTILLATES/PETROLEUM OIL
Fraction by Wt: BALANCE
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 AS OIL MIST
ACGIH TLV:5 MG/M3 AS OIL MIST
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATE, SOLVENT DEWAXED (MILD),
HEAVY PARAFFINIC/PETROLEUM LUBE OIL
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 AS OIL MIST
ACGIH TLV:5 MG/M3 AS OIL MIST
Ingred Name:HYDROTREATED LIGHT NAPHTHENIC PETROLEUM DISTILLATES/MINERAL
OIL
Fraction by Wt: 1 - 3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:METHACRYLIC ACID,COPOLYMER OF "BUTYL","LAURYL" AND
"STEARYL" ESTERS WITH 3-DIMETHYL-AMINOPROPYLMETHACRYLAMIDE
Fraction by Wt: 1 - 3%
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Ingred Name:BENZENEAMINE,N-PHENYL-1,2,4-TRIMETHYLBENZENE
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY &
GI TRACTS. ACUTE- MAY CAUSE MINIMAL EYE IRRITATION.
PROLONGED/REPEATED SKIN CONTACT MAY CAUSE SEVER IRRITATION.
INHALATION OF VAPOR (GENERATED AT HIGH TEMPERATUR ES)/MIST MAY
CAUSE IRRITATION, DROWSINESS. IF >SEVERAL MOUTHFULS ARE SWALLOWED
MAY CAUSE DISCOMFORT. CHRONIC- NONE .
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, NAUSEA, VOMITING, DIARRHEA,
HEADACHE, DIZZINESS
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.
* First Aid Measures *
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:MOVE TO FRESH
SKIN:WASH WITH SOAP & WATER. ORAL:IF MORE THAN SEVERAL MOUTHFULS OF
GET MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:COC
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL/CARBON DIOXIDE. WATER
OR FOAM MAY CAUSE FROTHING.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED OR CONFINED AREA
WITHOUT PROPER PROTECTIVE EQUIPMENT AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:PICK UP SPILL WITH INERT MATERIAL SUCH AS
SAND, CLAY, EARTH. SHOVEL INTO CONTAINERS FOR DISPOSAL. PREVENT
RUN-OFF TO ENTER WATERWAYS, SEWERS. REPORT SPILL TO AUTHORITY AS
REQUIRED.
Neutralizing Agent:NOT RELEVANT
*Handling and Storage *
Handling and Storage Precautions:MINIMUM FEASIBLE HANDLING TEMPERATURES
SHOULD BE MAINTAINED. PERIODS OF EXPOSURE TO HIGH TEMPERATURES
SHOULD BE MINIMIZED. AVOID WATER CONTAMINATION.
Other Precautions:AVOID CONTACT WITH EYES AND SKIN. WASH THOROUGHLY
AFTER HANDLING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE. AVOID
INHALING MISTS. EMPTY CONTAINERS RETAIN RESIDUE. FOLLOW LABEL
INSTRUCTIONS. DO NOT T AKE INTERNALLY.
* Physical/Chemical Properties *
HCC:V6
NRC/State Lic Num:NOT RELEVANT
Appearance and Odor:RED LIQUID, SLIGHT ADDITIVE ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
IRRITATING ALDEHYDES AND KETONES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN AN APPROPRIATE DISPOSAL FACILITY
IN COMPLIANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
INCINERATION IS RECOMMENDED.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCENTRATION EXCEEDS TLV, A
NIOSH-APPROVED DUST RESPIRATOR IS RECOMMENDED. IF CONCENTRATION
EXCEEDS CAPACITY OF RESPIRATOR, USE SELF-CONTAINED BREATHING
APPARATUS.
Ventilation:LOCAL EXHAUST IF OSHA LIMITS ARE EXCEEDED.
Other Protective Equipment:EYE WASH STATION, QUICK DRENCH SHOWER AND
IMPERVIOUS CLOTHING
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
NONE.
* Product Identification *
Preparer's Name:DEBORAH A. SHREVE
* Composition/Information on Ingredients *
Ingred Name:IRON OXIDE
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:5 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE- SLIGHTLY DUSTY MATERIAL MAY
CAUSE EYE, SKIN AND MUCOUS MEMBRANES IRRITATION. CHRONIC- NONE
KNOWN.
Effects of Overexposure:SLIGHTLY DUSTY MATERIAL MAY CAUSE EYE, SKIN,
AND MUCOUS IRRITATION.
Medical Cond Aggravated by Exposure:NONE KNOWN.
* First Aid Measures *
First Aid:GET MEDICAL ATTENTION IN ALL CASES. SKIN: WASH WITH SOAP AND
INHALED: REMOVE TO FRESH AIR AND PROVIDE OXYGEN/CPR IF NEEDED.
ORAL: GET MEDICAL HELP.
* Fire Fighting Measures *
Extinguishing Media:WATER, CARBON DIOXIDE
Fire Fighting Procedures:USE FOG NOZZLE AND FINE SPRAY TO PREVENT
DUSTING.
* Accidental Release Measures *
Spill Release Procedures:VACUUM AND CAREFULLY SWEEP UP MATERIAL INTO
CONTAINER AND DISPOSE OF ACCORDING TO FEDERAL, STATE AND LOCAL
*Handling and Storage *
Handling and Storage Precautions:STORAGE- KEEP MATERIAL CLEAN AND DRY.
IT IS ESSENTIAL THAT THE MATERIAL BE KEPT CLEAN AND DRY UNTIL READY
TO USE FOR BEST PERFORMANCE.
Other Precautions:DO NOT GENERATE DUSTS. AVOID BREATHING DUSTS. DO NOT
GET IN EYES, ON SKIN OR ON CLOTHING. WASH THOROUGHLY AFTER
HANDLING.
* Physical/Chemical Properties *
HCC:N1
NRC/State Lic Num:NONE
Spec Gravity:0.4
Solubility in Water:NEGLIGIBLE
Appearance and Odor:FOREST GREEN POWDER, ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:
Hazardous Decomposition Products:NOT KNOWN
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF ACCORDING TO FEDERAL, STATE, AND
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:DEPENDING ON NATURE & CONCENTRATION OF AIRBORNE
MATERIAL, USE A NIOSH/MSHA APPROVED GAS MASK WITH APPROPRIATE
CARTRIDGES & CANNISTERS OR SUPPLIED AIR EQUIPMENT.
Ventilation:USE EXPLO-PROOF VENT AS REQD TO CTL VAP CONC TO MAINTAIN
Other Protective Equipment:PROTECTIVE CLOTHING AS REQUIRED TO PREVENT
SKIN CONTACT.
Work Hygienic Practices:WASH W/SOAP & WATER BEFORE EATING, DRINKING,
SMOKING OR USING TOILET FACILITIES. LAUNDER CONTAMD CLTHG BEFORE
REUSE.
Supplemental Safety and Health
FIRE FIGHT PROC: BURNING LIQ W/WATER USED FOR COOLING PURPOSES. EXPLO
HAZ: ALUMINUM CONTRS/EQUIP. THERMAL DECOMP PROD MAY INCL HCL &
PHOSGENE . MATL TO AVOID: POWDERS SHOULD BE AVOIDED. EFTS OF
OVEREXP:HAVE PRODUCED SENSIT OF MYOCARDIUM TO EPINEPHRINE IN LAB
ANIMALS & COULD HAVE SIMILAR EFT IN HUMANS. (ING 5)
* Product Identification *
Preparer's Name:J.B.R.
* Composition/Information on Ingredients *
Ingred Name:ETHANE,1,1,1-TRICHLORO-; (1,1,1-TRICHLOROETHANE). VP:
Ozone Depleting Chemical:1
Ingred Name:AROMATIC PETROLEUM DISTILLATES; (HYDROCARBON MIXTURE).
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (AROMATIC
Ingred Name:SUPP DATA: ADRENOMIMETICS (E.G., EPHINEPHRINE) MAY BE
CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINING USES IN HUMANS (ING 6)
Ingred Name:ING 5:ACUTELY OR CHRONICALLY EXPOSED TO CHLOROCARBONS .
Ingred Name:FIRST AID PROC: INDUCE VOMIT. INDUCE VOMIT BY GIVING SYRUP
OF IPECAC-1 OZ FOLLOWED BY 8 OZ OF WATER.
Ingred Name:OTHER PREC: USE IN GEN VICIN OF ARC WELD, OPEN FLAMES/HOT
SURF. HEAT &/OR UV RADIA MAY CAUSE FORM OF HCL &/OR (ING 9)
Ingred Name:ING 8: PHOSGENE .
Ingred Name:VENT: EXHAUST SYSTEMS MAY BE REQUIRED.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: OVEREXP CAN LEAD TO CNS DEPRESS
PRDCG SUCH EFTS AS HDCH, DIZZ, NAUS, & LOSS OF CONSCIOUSNESS. EYE:
SHORT-TERM CONT MAY RSLT IN SLIGHT IRRIT. PRLNGD & RPTD CONT MAY BE
MORE IRRIT. SKIN: PRLNGD &RPTD LIQ CONT CAN CAUSE DEFAT &
DRYINGOF SKIN WHICH MAY RSLT IN IRRIT & DERM. TESTS SHOW OVEREXP
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:MAY CAUSE BLOOD DISORDERS & NEUROLOGIC
DISORDERS. CAUSES EYE & SKIN IRRIT. MAY CAUSE HDCH & DIZZ. HARMFUL
IF SWALLOWED. MAY CAUSE IRRIT TO RESP TRACT. RPTS HAVE ASSOC RPTD &
PRLNGD OCCUP OVER EXP TO SOLV W/PERM BRAIN & NERV SYS DAM.
INTENTIONAL MISUSE OF PROD MAY BE HARMFUL/FATAL. CHLOROLCARBON
MATLS(SUPP DATA)
Medical Cond Aggravated by Exposure:NONE.
* First Aid Measures *
MED ATTN. SKIN: WASH W/SOAP & WATER. REMOVE CONTAMD CLTHG & SHOES;
DO NOT REUSE UNTIL CLEANED. IF PRESISTENT IRRIT OCCURS, GET MED
ATTN. INH AL: REMOVE TO FRESH AIR & PROVIDE OXYGEN. IF BRTHG IS
DFCLT, GIVE ARTF RESP IF NOT BRTHG. GET MED ATTN. INGEST: SEEK EMER
MED ATTN. DO NOT GIVE ANYTHING BY MOUTH TO AN UNCON PERSON. DO NOT
(ING 7)
* Fire Fighting Measures *
Flash Point Method:SCC
Lower Limits:0.5%
Upper Limits:6%
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, WATER FOG, FOAM.
Fire Fighting Procedures:NIOSH/MSHA APPRVD PRESS DEMAND SCBA & FULL
PROT EQUIP. EVAC HAZ AREA OF UNPROTECTED PERS. COOL FIRE-EXPOSED
CONTRS W/WATER. AVOID SPREADING (SUPP DATA)
Unusual Fire/Explosion Hazard:THIS MATL IS FLAMM & MAY BE IGNITED BY
HEAT/SPARKS, FLAME/STATIC ELEC. EXPLO MAY OCCUR WHEN PROD CNTNG
1,1,1 TRICHLOROETHANE ARE STORED/USED IN (SUPP DATA)
* Accidental Release Measures *
Spill Release Procedures:STAY UPWIND & AWAY FROM SPILL. KEEP ALL
SOURCES OF IGNITION AND HOT METAL SURFACES AWAY FROM SPILL. IF
SPILL IS INDOORS, VENTILATE AREA OF SPILL. IF LARGE SPILL, CALL
SPILL RESPONSE TEAM. NOTIFY APPRO PRIATE STATE/LOCAL AGENCIES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT/SPARKS/OPEN FLAME.
KEEP CONTRS TIGHTLY CLSD. STORE AWAY FROM STRONG OXIDIZING AGENTS
IN A COOL, DRY PLACE W/ADEQ EXPLO-PROOF VENT.
Other Precautions:GROUND EQUIP TO PVNT ACCUMULATION OF STATIC CHARGE.
IF POUR/TRANSFERRING MATLS, CONTRS MUST BE BONDED & GROUNDED. DO
NOT WELD, HEAT/DRILL ON/NEAR CONTR; EVEN EMPTIED CONTRS CAN CNTN
EXPLOS VAPS. NO SM OKING IN AREA OF USE. DO NOT (ING 8)
* Physical/Chemical Properties *
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONT W/STRONG OXIDIZING AGENTS. AVOID PRLNGD CONT W/STOR IN,
ALUMINUM/ITS ALLOYS. METALLIC & ZINC (SUPP DATA)
Stability Condition to Avoid:AVOID HEAT, SPARKS, & OPEN FLAME. AVOID
CONTACT W/ALKALIES, AQUEOUS ACIDS, AMINES, AND ACIDIC ALCOHOLS.
Hazardous Decomposition Products:THERMAL DECOMPOSITION IN THE PRESENCE
OF AIR MAY YIELD CARBON MONOXIDE &/OR CARBON DIOXIDE. HCL &
PHOSGENE .
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF PRODUCT IN ACCORDANCE WITH LOCAL,
COUNTY, STATE, AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS.CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE,THROAT.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
* First Aid Measures *
First Aid:EYES:FLUSH W/WATER IMMED.SKIN:WASH W/SOAP IMMED.INHAL:REMOVE
TO FRESH AIR.GIVE ART.RESPIR. AS NEEDED.INGEST:GET MEDICAL
ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE VOMITING,BUT DO NOT MAKE
UNCONSCIOUS PE RSON VOMIT
* Accidental Release Measures *
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPRE AUTHORITIES.
*Handling and Storage *
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
* Physical/Chemical Properties *
HCC:Z3
Appearance and Odor:LIGHT STRAW COLORED LIQUID,AROMTIC ODOR
* Stability and Reactivity Data *
STRONG OXIDIZERS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NORMALLY NOT REQUIRED;USE NIOSH/MSHA APPROVED
RESPIRATOR FOR ORGANIC VAPORS/MIST AS REQUIRED IF ABOVE PEL/TLV OR
SCBA IN AN ENCLOSED AREA.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER,WORK
CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS.
* Product Identification *
Preparer's Name:P.A.PARKER
CAGE:0DHB8
* Composition/Information on Ingredients *
Ingred Name:SYNTHETIC HYDROCARBONS(DIESTER)
Ingred Name:OTHER COMPONENTS (TYPE NOT SPECIFIED)
* Hazards Identification *
Routes of Entry: Inhalation:UNKNOWN Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATION OF
EYES,SKIN,RESPIRATORY OR G.I.TRACTS;CNS EFFECTS LIKE
HEADACHE,DIZZINESS,NAUSEA AND VOMITING.CHRONIC:DRYING OF
SKIN,DEFATTING OR DERMATITIS POSSIBLE.
Explanation of Carcinogenicity:DATA PER MSDS
Effects of Overexposure:SEE HEALTH HAZARDS DATA.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
* First Aid Measures *
First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
SKIN:REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER. IF
IRRITATION PERSISTS, GET MEDICAL ADVICE. INGESTION:DO NOT INDUCE
VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET IMMEDIATE
MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:COC
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:EXPOSURE TO HEAT BUILDS UP PRESSURE IN
CLOSED CONTAINERS.FIRE OR EXCESSIVE HEAT MAY CAUSE PRODUCTION OF
HAZARDOUS DECOMPOSITION PRODUCTS.
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;REMOVE ALL
IGNITION SOURCES;CONTAIN FREE MATERIAL IF POSSIBLE;USE SUITABLE
INERT ABSORBENT MATERIAL AND RECOVER FOR PROPER DISPOSAL IN AN
APPROVED CONTAINER.
Neutralizing Agent:NOT APPLICABLE.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT
CONTAINERS FROM PHYSICAL DAMAGE.
Other Precautions:DO NOT BREATHE MIST. AVOID PROLONGED OR REPEATED
BREATHING OF VAPOR. AVOID CONTACT WITH EYES. USE WITH ADEQUATE
VENTILATION. WASH THOROUGHLY AFTER HANDLING.
* Physical/Chemical Properties *
HCC:V6
Spec Gravity:<1.0
Evaporation Rate & Reference:<1.0(N-BUTYL ACETATE = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:RED CLEAR LIQUID;MILD ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
OTHER UNIDENTIFIED COMPONENTS (TOXIC IN NATURE.).
* Disposal Considerations *
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES.DISPOSAL MUST BE MADE
IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF WORK STATION IS NOT PROPERLY VENTILATED TO
EXHAUST ALL FUMES, VAPORS AND DUSTS BELOW THE RECOMMENDED EXPOSURE
LIMITS, USE A NIOSH APPROVED RESPIRATOR.
Ventilation:USE ENOUGH GEN VENT & LOC EXHST AT WORK SITE TO KEEP ALL
FUMES & DUST FROM WORKER'S BREATHING ZONE & GENERAL AREA.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . HAND,
HEAD & BODY PROT. MAY INCL ARM PROT, APRONS, HATS & DARK PROT
CLTHG.
Work Hygienic Practices:TRAIN WORKERS NOT TO TOUCH LIVE ELECTRICAL
PARTS AND TO INSULATE THEMSELVES FROM WORK AND ELECTRICAL GROUND.
Supplemental Safety and Health
FIRE FIGHT PROC: & ALLIED PROCESSES. EXPLO HAZ: PRESS & FLAMS MAY
EXPLODE. HAZ DECOMP PRODS: NORM OPERATION INCL THOSE ORIGINATING
FROM VOLATILIZATION RXN OR OXIDATION OF MATLS LISTED PLUS THOSE OF
BA SE METAL & COATING, ETC. REASONABLY EXPECTED CONSTITUENTS OF
FUME MAY INCL COMPLEX OXIDES OF METALS LISTED. FLUX (ING 7)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:IRON
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CALCIUM CARBONATE
Ingred Name:POTASSIUM SILICATE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM SILICATE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:FLUORSPAR
OSHA PEL:N/K
ACGIH TLV:N/K
Fraction by Wt: 1-5%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:SUPDAT: COATINGS MAY PRDCE FLUORIDE CMPDS, METAL OXIDES,
CARBON & SILICA. GASEOUS RXN PRODS MAY INCL OZONE, CO, (ING 8)
Ingred Name:ING 7: CO*2, NITROGEN OXIDES & CERTAIN INERT GASES USED AS
SHIELDING GASES. OSHA SPECIFIES NICKEL & ITS CMPDS (ING 9)
Ingred Name:ING 8: MUST BE CONSIDERED CARCINS BECAUSE THEY ARE SO
Ingred Name:ING 9:SCIENTIFIC STUDIES SHOWING WORKERS EXPOS TO ALLOY
Ingred Name:EFTS OF OVEREXP: OPERATIONS. SYMPS ARE SIMILAR TO FLU TYPE
OR PNEUMOCONIOSIS. FOR MORE HLTH HAZ INFO CNTCT NEHC .
Ingred Name:EYE PROT: & FULL LENGTH FSHLD . PROVIDE PROT SCREENS &
LIGHTER SHADE WHICH GIVES SUFFICIENT VIEW OF WELD ZONE.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL:FUMES ASSOC W/HEATING, WELDING,
BRAZING, SOLDERING/CUTTING METALS CAN BE DANGEROUS TO HLTH &
OVEREXP CAN CAUSE LUNG DMG &/OR OTHER ORGAN DMG. ARC RAYS & UV
LIGHT CAN INJURE EYE & BURN SKIN. INGE ST:MAY BE HARMFUL/FATAL IF
SWALLOWED. GEN WELDING FUMES CAN CREATE ONE/MORE OF FOLLOWING:
FUMES, GASES (EFTS OF OVEREXP)
CARCIN.
Effects of Overexposure:HLTH HAZ: & DUSTS CAN BE DANGEROUS TO HLTH.
SHORT TERM OVEREXP MAY RSLT IN DIZZ, NAUS OR DRYNESS/IRRIT OF NOSE,
THROAT/EYES. EXCESS OVEREXP MAY CAUSE BRONCH ASTHMA, LUNG FIBROSIS,
PNEUMOCONIOSIS OR SI DEROSIS (IRON DEPOSITS IN LUNG). METAL FUME
FEVER CAN BE CAUSED BY INHAL OF CERTAIN METALLIC CMPDS DURING (ING
Medical Cond Aggravated by Exposure:AGGRAVATION OF PREEXISTING
RESPIRATORY OR ALLERGIC CONDITIONS MAY OCCUR IN SOME WORKERS.
* First Aid Measures *
First Aid:INHAL:MOVE VICTIM TO FRESH AIR SOURCE. CNTCT MD & ADVISE ON
INGREDS LISTED. SKIN: THOROUGHLY WASH HANDS/EFFECTED AREAS W/SOAP &
WATER TO REMOVE ALL RESIDUE. IF RASH/BURN DEVELOPS CONSULT MD. EYE:
OBTAIN PROMPT MED ADVICE FOR FLUXES & CHEM AIDS. ADVISE MD OF
INGREDS LISTED. INGEST: CALL MD &/OR POIS CTL CTR. ADVISE OF
INGREDS LISTED.
* Fire Fighting Measures *
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL FOAM TYPE.
Fire Fighting Procedures:NIOSH APPRVD SCBA & FULL PROT EQUIP . TOX
FIRE PREVENTION DURING USE OF WELDING(SUPDAT)
Unusual Fire/Explosion Hazard:GEN NONFLAM; WELDING ARC, SPKS & FLAMES
CAN IGNITE COMBUSTS & FLAMS. SOME FLUXES & CHEM AIDS MAY GIVE OFF
HCL, PHOSGENE & CHLORINE GASES. CANS UNDER (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:PLEASE READ AND UNDERSTAND PRODUCT
LABEL INFO FOR PROPER PROCEDURES & USE.
FOR MORE DETAILS. TRAIN WELDER TO KEEP HIS/HER FACE AWAY FROM
FUME/DUST PLUME.
* Physical/Chemical Properties *
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:DURING WELDING, FUME & GAS DECOMP
PRODS GENERATED DIFFER IN PERCENT & FORM FROM LISTED INGREDS.
DECOMP PRODS OF (SUPDAT)
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF WASTE MATL, PWDRS, GRINDING OR FILTER
RESIDUES IN ENVIRONMENTALLY SENSITIVE MANNER I/A/W FED, STATE &
LOCAL REGS. USE APPROP MEASURES TO KEEP AIRBORNE DUST LEVELS
CONTAINED I/A/W EXPOS LEVE LS LISTED. SEE ALSO SECTION ON SAFE
HNDLG & STOR.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IN TIMES OF OVEREXPOSURE AT LEVEL EXCEEDING
AIR/SELF-CONTAINED BREATHING APPARATUS.
Ventilation:GENERAL EXHAUST IS USUALLY ADEQUATE.
Other Protective Equipment:SHOES OR BOOTS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Preparer's Name:KEVIN UHL
* Composition/Information on Ingredients *
Ingred Name:METHANE, DICHLORODIFLUORO-; (DICHLORODIFLUOROMETHANE)
(SARA III)
Ozone Depleting Chemical:1
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY BE IRRITATING TO EYES OR TO
PERSONS WITH VERY SENSITIVE SKIN. THIS INGREDIENT IS VERY VOLATILE.
CONTACT WILL BE MINIMAL. VAPORIZING IN SECONDS. CHRONIC EFFECTS:
UNLIKELY UNLESS OVEREXPOSURE COMES ABOUT IN ENCLOSED AREAS
W/LITTLEOXYGEN OR VENTILATION. (SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: CHLOROFLUOROCARBON (CFC) MATLS HAVE
PRDCED SENSITIZATION OF MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS &
MAY HAVE A SIMILAR EFT IN HUMANS. ADRENOMIMETICS (I.E.,EPINEPHRINE)
MAY BE CONTRA-INDIC ATED EXCEPT FOR LIFE-SUSTAINING USES INHUMANS
ACUTELY OR CHRONICALLY EXPOSED TO CFC'S .
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. ARTIFICIAL RESPIRATION AND OXYGEN
IF BREATHING HAS STOPPED. SEE MD. EYES/SKIN: TREAT FOR FROSTBITE.
SEE MD. INGEST: CALL MD IMMEDIATELY .
* Fire Fighting Measures *
Flash Point Method:TCC
Flash Point:NON-FLAMMABLE
Extinguishing Media:"ALCOHOL" FOAM, CO*2, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures:PROD IS NON-FLAMM. SPRAY EXPOSED CONTRS
W/WATER TO KEEP CANS FROM RUPTURING. WEAR NIOSH/MSHA APPRVD
PRESSURE DEMAND SCBA & FULL PROTECTIVE EQUIPMENT
Unusual Fire/Explosion Hazard:NOT APPLICABLE. THERMAL DECOMPOSITION
PRODUCTS MAY INCLUDE FLUORIDES, CHLORIDES, AND PHOSGENE .
* Accidental Release Measures *
Spill Release Procedures:CLEAR AREA AND VENTILATE TO REMOVE VAPORS.
*Handling and Storage *
Other Precautions:KEEP OUT OF REACH OF CHILDREN. READ ENTIRE LABEL
BEFORE USING PROD. NO SMKG IN AREA OF USE. DO NOT USE IN GEN VICIN
OF ARC WELDING/OPEN FLAMES/HOT SURF. HEAT &/OR UV RADIATION MAY
CAUSE FORMATION OF C HLORIDES, FLUORIDES OR PHOSGENE .
* Physical/Chemical Properties *
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS. ETHERED ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CHEMICALLY ACTIVE METALS.
Stability Condition to Avoid:HIGH TEMPERATURES OR OPEN FLAME.
Hazardous Decomposition Products:PHOSGENE, FLUORIDES, HALIDE ACIDS.
CHLORIDES .
* Disposal Considerations *
Waste Disposal Methods:EVAPORATE OUTSIDE IN OPEN AREAS. DISPOSAL MUST
BE IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST
Other Protective Equipment:SAFETY SHOWER, EYE BATH, PROTECTIVE CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:POLY(OXY-1,2-ETHANEDIYL),
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE HARMFUL BY INHALATION,
INGESTION/SKIN ABSORPTION. MAY BE IRRITATING TO EYES, MUCOUS
MEMBRANES & UPPER RESPIRATORY TRACT. SKIN: IRRITATION. MAY AFFECT
THE MALE & FEMALE REPRODUCTIVE SYSTEM.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
* First Aid Measures *
MINS. SKIN: WASH W/SOAP & COPIOUS AMOUNTS OF WATER. INHALATION:
REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NECESSARY. INGESTION: WASH
OUT MOUTH W /WATER IF CONSCIOUS. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, CO2, DRY CHEMICAL POWDER/APPROPRIATE
FOAM
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING TO PREVENT CONTACT W/SKIN & EYES. . PREVENT
CONTACT W /SKIN/EYES. COOL CONTAINERS W/WATERSPRAY
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
* Accidental Release Measures *
Spill Release Procedures:WEAR SELF CONTAINED BREATHING APPARATUS,
UP, KEEP IN A CLOSED CONTAINER & HOLD FOR WASTE DISPOSAL. VENTILATE
AREA & WASH SITE AFTER MATERIAL PICKUP IS COMPLETE.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP
TIGHTLY CLOSED. WEAR SUITABLE PROTECTIVE CLOTHING.
Other Precautions:AVOID CONTACT & INHALATION. DON'T GET IN EYES, ON
SKIN/ON CLOTHING.
* Physical/Chemical Properties *
Appearance and Odor:VISCOUS LIGHT YELLOW LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG REDUCING AGENTS
Stability Condition to Avoid:FIRE
Hazardous Decomposition Products:CO, CO2
* Disposal Considerations *
Waste Disposal Methods:DISSOLVE/MIX THE MATERIAL W/A COMBUSTIBLE
SOLVENT & BURN IN A CHEMICAL INCINERATOR EQUIPPED W/AN AFTERBURNER
& SCRUBBER. DISPOSE OF IAW/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR NIOSH APPROVED RESPIRATORY PROTECTION WHEN
THE PRODUCT IS MIXED OR APPLIED IN A POORLY VENTILATED AREA OR IF
WORKPLACE LEVELS OF INGREDIENTS EXCEED THE TLV. FOLLOW APPLICABLE
FEDERAL, STATE, AND LOCAL REGULATIONS.
Ventilation:USE LOCAL EXHAUST (E.G., OPEN WINDOWS, FANS) AS NEEDED TO
KEEP VAPOR/DUST LEVELS BELOW RECOMMENDED LIMITS.
Other Protective Equipment:ANSI APPRVD EMER EYE WASH & DELUGE SHOWER .
CLEAN PROTECT CLTHG TO COVER ARMS & LEGS & KEEP EXPOSURE TO A MIN.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EVAP RATE: SLOWER (RELATIVE TO N-BUTYL ACCTATE) FIRE FIGHT PROC:
FROTHING W/SUBSEQUENT SPREAD OF FIRE. EXPLO HAZ: TRAVEL ALONG THE
GROUND/FLOOR & BE IGNITED AT LOCATIONS DISTANT FROM THE SOURCE.
* Product Identification *
Preparer's Name:MARK HORTON
CAGE:CHEMR
CAGE:CHEMR
* Composition/Information on Ingredients *
Ingred Name:CALCIUM OXIDE; (CALCIUM OXIDE [LIME])
OSHA PEL:5 MG/M3
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (SILICONE DIOXIDE)
Fraction by Wt: <1%
OSHA PEL:SEE TABLE Z-3
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (TALC
(HYDROUS MAGNESIUM SILICATE)
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (LIGHT
Fraction by Wt: 2-8%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BENZENE, 1,2,4-TRIMETHYL-; (1,2,4-TRIMETHYLBENZENE) (SARA
Fraction by Wt: 2-4%
Ingred Name:STODDARD SOLVENT (MINERAL SPIRITS (STODDARD TYPE) LEL: 1%
Fraction by Wt: 3-6%
Ingred Name:ISOCYANIC ACID, METHYL-M-PHENYLENE ESTER; (MIXED ISOMERS)
Fraction by Wt: <0.1%
OSHA PEL:N/K
Ingred Name:SUPDAT:BRONCHITIS, BRONCHIAL SPASMS, & PULM EDEMA (FLUID IN
&/CONTENTS (PROCESS CALLED SNIFFING) MAY BE HARMFUL/FATAL.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES:MOD IRRIT, MAY CAUSE
REVERSIBLE CORNEAL INJURY. SKIN:REGARD THIS PROD AS A SEVERE IRRIT.
THE PROD MAY CNTN TRACES AMTS OF AN ISOCYANATE, A CLASS OF CMPD
GENERALLY REGARDED AS PRIMARY SKIN I RRIT. CNTCT W/THE PRDCE MAY
CAUSE DERM,ALLERGIC RESPONSES, & IN SENSITIVE INDIVIDUALS, REDNESS,
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC
ANNUAL REPORT ON (SUPDAT)
Effects of Overexposure:HLTH HAZ:SWELL, & BLISTERS. INHAL:REGARD THIS
PROD AS A SEVERE IRRIT. THE PROD MAY CNTN TRACES AMTS OF
ISOCYANATE. EXPOS TO CONC OF AIRBORN ISOCYANATES ABOVE THE TLV AWAY
PRDCE IRRIT OF THE RESP TRACT , COUGHING, CHEST DISCOMFORT,
SHORTNESSOF BRTH. INDIVIDUALS WITH A HISTORY OF EXPOS TO
ISOCYANATES CAN (SUPDAT)
Medical Cond Aggravated by Exposure:ANY PRE-EXISTING RESPIRATORY OR
SKIN CONDITION.
* First Aid Measures *
First Aid:INGEST: CALL MD IMMEDIATELY . INHAL: REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . EYES: IMMEDIATELY FLUSH
MD . SKIN: FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD . FOR MORE
SPECIFIC INFORMATION CONTACT NEHC .
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1%
Upper Limits:7%
Extinguishing Media:WATER SPRAY (FOG), FOAM, DRY CHEMICAL OR CARBON
DIOXIDE.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
CNTNRS EXPOSED TO FIRE SHOULD BE KEPT COOL W/VAP SPRAY. A WATER
STREAM DIRECTED INTO THE FIRE MAY CAUSE (SUPDAT)
Unusual Fire/Explosion Hazard:CLSD CNTNRS MAY EXPLODE DUE TO BUILD UP
OF PRESS WHEN EXPOS TO HEAT. THERMAL DECOMP/COMBUST OF PROD MAY
GENERATE IRRIT &/TOXIC GASES. VAP/HVR & MAY (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:VENT THE AREA & REMOVE ALL SOURCES OF
IGNITION. DIKE/IMPOUND. COVER W/ABSORBENT SWEEP/SHOVEL. RINSE
W/WATER. FOR MORE SPECIFIC INFORMATION CONTACT NEHC .
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID CONTACT WITH EYES, CLOTHING, AND
SKIN. KEEP CONTAINER CLOSED WHEN NOT IN USE. KEEP OUT OF REACH OF
CHILDREN. DO NOT TAKE INTERNALLY.
Other Precautions:KEEP AWAY FROM EXTREME, HEAT AND OPEN FLAMES. AVOID
BREATHING VAPORS, ESPECIALLY THOSE IN THE TOP OF THE SHIPPING
CONTAINER. USE WITH ADEQUATE VENTILATION.
* Physical/Chemical Properties *
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:APPROX 1.3
Evaporation Rate & Reference:SLOWER (REL TO BU AC)
Solubility in Water:SLIGHT [<1%]
Appearance and Odor:SMOOTH BLACK VISCOUS PASTE. STRONG SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
WATER, ALCOHOLS AMINES, STRONG OXIDANTS, STRONG BASES OR ACIDS.
Stability Condition to Avoid:CONTACT WITH WATER VAPOR. SOURCES OF
IGNITION. LONG TERM EXPOSURE TO ELEVATED TEMPERATURES.
Hazardous Decomposition Products:FUMES, SMOKE. OXIDES OF CARBON &
NITROGEN, HYDROGEN CYANIDE GAS. ALDEHYDES, PHENOLS, AND ACIDS FROM
INCOMPLETE COMBUST.
Conditions to Avoid Polymerization:THIS PROD MAY CONTAIN AN ISOCYANATE.
CONTACT W/MOISTURE OR OTHER MATS THAT REACT W/ISOCYANATES MAY CAUSE
POLYMERIZATION.
* Disposal Considerations *
Waste Disposal Methods:REVIEW ALL LOCAL, STATE, AND FEDERAL REGULATIONS
CONCERNING HEALTH AND POLLUTION FOR APPROPRIATE DISPOSAL
PROCEDURES. DO NOT INCINERATE CLOSED CONTAINERS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NORMALLY REQUIRED. DLA-HMIS:IF ENGINEERING
CONTROLS FAIL OR NON-ROUTINE USE OR AN EMERGENCY OCCURS; WEAR AN
MSHA/NIOSH APPROVED RESPIRATOR OR AN AIR-SUPPLIED RESPIRATOR OR
Ventilation:USE ADEQUATE MECHANICAL VENTILATION OR LOCAL EXHAUST TO
MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:LAB COAT, EYE WASH STATION & SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:LUMINOL OR 5-AMINO-2, 3-DIHYDRO-1, 4-PTHALAZINEDIONE
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY CAUSE SKIN & EYE
IRRITATION. INGESTION MAY CAUSE GATROINTESTINAL DISCOMFORT.
INHALATION MAY CAUSE IRRITATION TO RESPIRATORY TRACT. CHRONIC: NONE
SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:SKIN-IRRITATION. EYES-IRRITATION. INGESTED-GI
TRACT IRRITATION. INHALED-RESPIRATORY IRRITATION.
Medical Cond Aggravated by Exposure:NO DATA AVAILABLE.
* First Aid Measures *
First Aid:IN ALL CASES GET MEDICAL ATTENTION. EYES-FLUSH WITH WATER FOR
THOROUGHLY WITH WATER. INHALED-REMOVE TO FRESH AIR. ADMINISTER
OXYGEN O R ARTIFICIAL RESPIRATION AS NEEDED. INGESTED-IF CONSCIOUS,
GIVE PLENTY OF WATER, LIFT LIDS. CONTACT POISON CONTROL CENTER &
OBTAIN IMMEDIATE MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL FIRE FIGHTER'S PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCES TOXIC
FUMES.
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA OF SPILL. CLEAN-UP PERSONNEL
SHOULD WEAR PROPER PROTECTIVE EQUIPMENT. AVOID CREATING DUST. SWEEP
OR SCOOP UP AND CONTAINERIZE FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED & PROTECTED FROM
PHYSICAL DAMAGE. STORE AT CONTROLLED ROOM TEMPERATURE AWAY FROM
OXIDIZING MATERIALS.
Other Precautions:DO NOT BREATH DUST. DO NOT GET IN EYES, ON SKIN OR ON
CLOTHES.
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:APPRECIABLE
Appearance and Odor:YELLOW POWDER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:OXIDES OF NITROGEN (NOX), OXIDES OF
CARBON (COX).
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL ENVIRONMENTAL REGULATIONS. ALWAYS CONTACT A PERMITTED WASTE
DIPOSER (TSD) TO ASSURE COMPLIANCE. EPA HAZWASTE NUMBER: NONE.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:CONTROL ENVIR CONCS BELOW APPLIC STDS. APPRVD
CHEMICAL MECHANICAL FILTER RESP DESIGNED TO REMOVE COMBIANTIONS OF
Ventilation:ALL APPLICATION AREAS SHOULD BE VENTILATED I/A/W OSHA
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FL PT METH:SETA/TCC. EXPLO HAZ:IRRITANT AND/OR TOXIC GASES. EFTS OF
OVEREXP: IS POISONOUS & CAN'T BE MADE NONPOISONOUS. INGEST MAY BE
FATAL/CAUSE BLNDNESS. CHRONIC EFTS OF PRLNGD OVEREXP TO SOLVS MAY
INCL DMG TO/AGGRAVATION OF MED CNDTNS INVOLVING LIVER, KIDNEYS & GI
TRACT AS WELL AS EFTS DESCRIBED EARLIER IN SECTION.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:PETROLEUM DISTILLATE. VP:2.0. LEL:1.0%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:OTHER PREC:WASTE CONTAINING OIL BASED PAINT/VARNISH THAT
PRESENT LG AIR-TO-OIL INTERFACE WILL OXIDIZE & MAY (ING 3)
Ingred Name:ING 2:IGNITE SPONT & SHOULD BE PLACED IN METAL CONTAINER.
KEEP OUT OF THE REACH OF CHILDREN.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:IRRIT OF RESP TRACT.
PRLNGD INHAL MAY LEAD TO FATG, DROW, DIZZ &/OR LT HEAD, HDCH, LACK
OF COORDINATION, NAUS, VOMIT, CNS DEPRESS, ANESTH EFT/NARC.
SKIN:IRRIT PRLNGD/RPTD CONT CAN CAUSE DE RM, DEFAT. EYE:IRRIT.
PRLNGD/RTPD CONT CAN CAUSE BLURRED VISION, REDNESS, TEARING, SEV
IRRIT. INGEST: (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:INGEST OF LG AMTS MAY CAUSE LUNG
INFLAMM & DMG DUE TO ASPIR OF MATL INTO LUNGS. NOTICE:RPTS HAVE
ASSOC RPTD & PRLNGD OCCUP OVEREXP TO SOLVS W/PERM BRAIN & NERV SYS
DMG. INTENTIONAL MISUSE BYDELIB CONCENTRATING & INHALING
CONTENTSMAY BE HARMFUL/FATAL. SUPP HLTH INFO:GROUP I IS DENATURED
ALCOHOL WHICH (SUPDAT)
Medical Cond Aggravated by Exposure:LIVER, KIDNEYS, & GASTROINTESTINAL
TRACT CONDITIONS.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
HAVE TRAINED PERSON GIVE OXYG IF NEC. GET EMER MED ATTN. SKIN:WASH
OFF QUICKLY W/PLENTY OF WATER, THEN SOAP & WATER; REMOVE CONTAMD
CLTHG. WASH CONTAMD CLTHG BEFORE REUSE. EYE:FLUSH IMMED W/LG AMTS
TREATMENT. INGEST:OBTAIN MEDICAL TREATMENT IMMEDIATELY.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:0.8%
Extinguishing Media:DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL & PROTECT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLSD CNTNRS MAY EXPLODE WHEN EXPOS TO
EXTREME HEAT/FIRE. VAPS CAN FORM EXPLO MIX IN AIR @ ELEVATED TEMPS.
MAY DECOMPOSE UNDER FIRE CNDTNS EMITTING (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION (FLAME, HOT
SURFACES, & ELECTRICAL, STATIC SPARKS). VENTILATE AREA & AVOID
BREATHING VAPORS. CONTAIN & REMOVE WITH INERT ABSORBENT MATERIAL
USING NON-SPARKING TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
QTYS IN BUILDINGS DESIGNED FOR STORAGE OF FLAMM/COMBUST LIQS. DO
NOT TAKE INTERNALLY.
Other Precautions:DO NOT WELD/FLAME CUT W/OUT PROPER VENT TO INSURE
AREA IS FREE OF FLAMM VAPS. DO NOT CUT, PUNCTURE/WELD ON OR NEAR
CNTNR. ENTRANCE INTO CLSD STOR TANKS-USE APPROP NIOSH APPRVD
RESP/AIRLINE FOR POSS EX POS TO SOLV/CHEM FUMES. RAGS OR (ING 2)
* Physical/Chemical Properties *
Vapor Pres:SEE ING
Evaporation Rate & Reference:SLOWER THAN ETHYL ETHER
Solubility in Water:NOT KNOWN
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, BASES, AMINES.
Stability Condition to Avoid:ELEVATED TEMPERATURES. CONTACT WITH
OXIDIZING AGENTS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH APPROVED SUPPLIED AIR RESPIRATORY
PROTECTION OR APPROVED NUISANCE DUST MASK IN CONFINED OR ENCLOSED
PLACES IF NEEDED.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER, WORK
CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
FORMULA CHANGED. FOR PREVIOUS FORMULATION, SEE P/N A UNDER THE SAME
NSN. HALOGENATED EXTINGUISHING AGENTS SUCH AS HALON SHOULD NOT BE
USED . TO CONTROL THE SPREAD OF FIRE, DO NOT USE WATER. ELIMINATE
DRAFTS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ALUMINUM (SARA III)
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICON
Fraction by Wt: <1.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:IRON
Fraction by Wt: <1.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:COPPER (SARA III)
Fraction by Wt: <4.9%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1MG/M3 FUME/1 DUST
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE- HIGH EXPOSURE TO ALUMINUM
POWDER MAY PRODUCE IRRITATION OF EYES AND RESPIRATORY TRACT.
CHRONIC- NOT KNOWN.
Effects of Overexposure:HIGH EXPOSURE TO ALUMINUM POWDER MAY PRODUCE
IRRITATION OF EYES AND RESPIRATORY TRACT.
Medical Cond Aggravated by Exposure:MAY AGGRAVATE PRE-EXISTING UPPER
RESPIRATORY AND LUNG DISEASES SUCH AS, BUT NOT LIMITED TO,
BRONCHITIS, EMPHYSEMA AND ASTHMA.
* First Aid Measures *
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. SKIN:WASH WITH
OPEN. INHALED:REMOVE TO FRESH AIR. ORAL:NONE NECESSARY.
* Fire Fighting Measures *
Extinguishing Media:RING SMALL FIRES WITH DRY SAND, USING NON-SPARKING
SHOVELS. AVOID CREATING DUST CLOUDS. LET FIRE EXTINGUISH ITSELF.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS WITH FULL
FACEPIECE OPERATED IN THE POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:AL DUST MAY BE IGNITED BY STATIC
DISCHARGE & BURN AT EXTREMELY HIGH TEMPERATURE. IT IS EXPLOSIVE
OVER A WIDE RANGE OF LOADINGS DEPENDING ON PARTICLE SIZE.
* Accidental Release Measures *
Spill Release Procedures:USE SOFT BRUSH AND PICKUP WITH NON-SPARKING
CONDUCTIVE SCOOPS OR VACUUM. USE ONLY VACUUM CLEANERS SPECIFICALLY
APPROVED FOR REMOVING REACTIVE COMBUSTIBLE METAL DUST. AVOID
CREATION OF DUST OR DISPERSI NG POWDER IN AIR. DO NOT USE WATER.
*Handling and Storage *
Handling and Storage Precautions:STORAGE- STORE IN A CLEAN, DRY AREA
AWAY FROM STATIC ELECTRICITY AND INCOMPATIBLE MATERIALS.
Other Precautions:AVOID BREATHING OF DUSTS. AVOID CONTACT WITH EYES &
SKIN. USE WITH ADEQUATE VENTILATION. PROPER GROUNDING OF ELECTRICAL
EQUIPMENT IS ESSENTIAL. USE NON-SPARKING, CONDUCTIVE TOOLS. AVOID
ACCUMULATIONS OF DUST AND STATIC BUILD-UP & DISCHARGE.
* Physical/Chemical Properties *
HCC:F8
Spec Gravity:2.7
Solubility in Water:INSOLUBLE
Appearance and Odor:METAL POWDER, SILVER-GREY COLOR, ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
WATER, SOME ACIDS, ALKALIES, HALOGENATED COMPOUNDS
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS, STATIC ELECTRICITY
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:ALUMINUM IS NOT LISTED AS A TOXIC OR HAZARDOUS
WASTE. HOWEVER, ALUMINUM POWDER MAY MEET THE CRITERIA FOR WATER
REACTIVE MATERIALS AND MAY BE REGULATED AS SUCH. DISPOSE OF IN
ACCORDANCE WITH ALL LOCAL,STATE AND FEDERAL REGULATIONS OR
RECYCLE IT.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE A SELF-CONTAINED BREATHING APPARATUS IF
>TLV.
Ventilation:ADEQUATE
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING/FOOTWEAR
BEFORE REUSE. DISCARD IF UNABLE TO DECONTAMINATE.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:LEAD SULFOCHROMATE YELLOW, CHROME YELLOW LIGHT
Ingred Name:TITANIUM DIOXIDE
Ingred Name:METHYLENE CHLORIDE(SARA III)
Ingred Name:TOLUENE (SARA III)
Ingred Name:ACETONE (SARA III)
Ingred Name:MINERAL SPIRITS
Ingred Name:VM&P NAPHTHA (LIGROINE)
Ingred Name:ETHYL ALCOHOL (ETHANOL)
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
Ingred Name:2-BUTOXYETHANOL
Fraction by Wt: 1.5%
Ingred Name:PROPANE
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE: INFLAMMATION. SKIN:
IRRITATION/BURN/HARMFUL IF ABSORBED. INHALATION: CNS
DEPRESSION/STUPOR/COUGH/VOMITING/IRRITATION OF RESPIRATORY TRACT &
MUCOUS MEMBRANE/WEAKNESS/DROWSINESS/HARMFUL. INGESTION: GI TRACT
IRRITATION/CNS
DEPRESSION/DEATH/FATIGUE/BLINDNESS/HARMFUL/DIARRHEA/MENTAL
CONFUSION/APPETITE LOSS/VOMITING.
Explanation of Carcinogenicity:METHYLENE CHLORIDE & LEAD ARE SUSPECTED
A2 CARCINOGENS.
Effects of Overexposure:EYE: RED/TEAR/BLURRED VISION. SKIN:
RED/ROUGH/DRY/DERMATITIS/DEFAT. INHALATION: MUSCULAR
INCOORDINATION/DEATH/CNS, BRAIN CELL, LIVER, & KIDNEY
DAMAGE/ASPHYXIATION/ACIDOSIS/NARCOSIS/BLINDNESS. INGESTIO N:
CHEMICAL PNEUMONIA/PULMONARY EDEMA/HEMORRHAGE/ANEMIA/EFFECTS TO
URINARY/REPRODUCTIVE SYSTEMS INCLUDING EMBRYOTOXIC.
* First Aid Measures *
First Aid:EYE: FLUSH W/WATER. SKIN: WASH W/SOAP/WATER/SOOTHING
OINTMENT. INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN.
INGESTION: DON'T INDUCE VOMITING UNLESS LARGE AMOUNTS INGESTED.
STICK FINGER DOWN THROA T. AVOID VOMITUS ASPIRATION INTO LUNGS.IF
VOMITING OCCURS, KEEP HEAD BELOW HIPS. NEVER GIVE ANYTHING BY MOUTH
IF UNCONSCIOUS. GIVE 2 GLASSES OF WATER. OBTAIN MEDICAL ATTENTION
IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:TOC
Extinguishing Media:CO2, DRY CHEMICAL, OR FOAM
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS
USED, FOG NOZZLES ARE PREFERABLE. WEAR SELF-CONTAINED BREATHING
APPARATUS.
Unusual Fire/Explosion Hazard:USE WATER TO COOL CONTAINERS TO PREVENT
BURSTING OF AEROSOL CANS DUE TO HEAT OR SUNLIGHT.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE
AREA. WIPE UP W/INERT MATERIALS & PLACE IN APPROPRIATE CONTAINER.
*Handling and Storage *
Handling and Storage Precautions:AVOID CONTINUOUS BREATHING OF SOLVENT
VENTILATION. AVOID CONTACT W/SKIN & EYES.
Other Precautions:USE ONLY AS DIRECTED. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING VAPORS & INHALING CONTENTS CAN BE
HARMFUL OR FATAL.
* Physical/Chemical Properties *
Vapor Density:>AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:AEROSOL
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
LIGHTS, OPEN FLAME, SUNLIGHT, OR OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:HAZARDOUS FUMES CONTAINING CO2, CO,
HYDROGEN CHLORIDE VAPOR, & TRACES OF PHOSGENE
* Disposal Considerations *
Waste Disposal Methods:DON'T INCINERATE AEROSOL. DISPOSE OF IN
ACCORDANCE W/LOCAL, STATE, & FEDERAL REGULATIONS. DON'T PLACE
AEROSOL CANS IN HOME COMPACTOR. DON'T PUNCTURE.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:CARTRIDGE-TYPE RESPIRATOR
Ventilation:LOCAL EXHAUST TO KEEP BELOW GIVEN TLV & LEL
Other Protective Equipment:USE APPROPRIATE INDUSTRIAL HYGINENE
PRACTICES.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:TRICHLOROETHYLENE (SARA III)
Ingred Name:NAPHTHA (PETROLEUM SPIRITS OR BENZIN)
* Hazards Identification *
Effects of Overexposure:HEADACHE,NAUSEA,IMPAIRMENT OF REACTION TIME &
COORDINATION.VAPORS MAY BE TOXIC.
* First Aid Measures *
First Aid:INHAL:MOVE TO FRESH AIR.RESTORE BREATHING. SKIN:WASH W/SOAP &
MIN.CALL DR.
* Fire Fighting Measures *
Upper Limits:9.0.
Extinguishing Media:FOAM,CO*2,DRY CHEMICAL
Fire Fighting Procedures:WATER FROM FOG NOZZLES MAY BE USED TO COOL
CLOSED CONTAINERS
* Accidental Release Measures *
Spill Release Procedures:AVOID PROLONGED CONTACT WITH SKIN & BREATHING
OF VAPOR.VAPORS MAY BE TOXIC.REMOVE SOURCES OF IGNITION.REMOVE WITH
INERT ABSORBENT & NON-SPARKING TOOLS.VENTILATE AREA.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT,SPARKS,AND OPEN
Other Precautions:WASH WELL AFTER HANDLING & BEFORE EATING OR
SMOKING.CONTAINERS SHOULD BE GROUNDED WHEN POURING.
* Physical/Chemical Properties *
HCC:V4
Evaporation Rate & Reference:<1.0,ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:HAZY STRAW COLORED LIQUID;STRONG SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE
Hazardous Decomposition Products:CO,CO*2,SMOKE & CHLORINE VAPORS
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL METHOD MUST COMPLY WITH LOCAL,STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED CANISTER TYPE RESPIRATOR
MUST BE WORN TO PREVENT INHAL OF VAPORS OR SPRAY MISTS WHEN TLV OR
PEL IS EXCEEDED. WHERE NIOSH/MSHA APPROVED DUST MASK WHEN SANDING
CURED PRODUCT.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GEN &/OR LOC) EXHAUST
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment:REMOVE AND WASH CONTAMINATED CLOTHING. USE
Work Hygienic Practices:WASH HANDS BEFORE EATING AND DO NOT SMOKE WHILE
USING.
Supplemental Safety and Health
EFTS OF OVEREXP:/PAIN & DISCOMFORT.
* Product Identification *
Preparer's Name:JEFF ZYCH
* Composition/Information on Ingredients *
Ingred Name:POLYESTER RESIN
Ingred Name:TOLUENE (SARA III)
Fraction by Wt: 4%
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (TALC)
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL OF RPTD HIGH CONC MAY CAUSE
LIVER/KIDNEY DAM. INT'L AGENCY FOR RESEARCH ON CANCER (IARC) HAS
CLASSED STYRENE AS POSS HUMAN CARCIN (CLASS 2-B). 2-B
CLASSIFICATION IS NOT BASED ON NEW EVIDENCE THA T STYRENE MIGHT BE
CARCINOGEN BUT ON REVISED IARC CLASSIFICATION SYS & NEW EVIDENCE
FOR STYRENE OXIDE. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:STYRENE: CLASS 2B (IARC).
Effects of Overexposure:HLTH HAZ:INHAL:VAP MAY CAUSE NOSE/THROAT/RESP
TRACT IRRIT. HIGH CONC MAY CAUSE HDCH/NAUS. RPTD HIGH CONC EXPOS
MAY CAUSE LIVER & KIDNEY DAM. SKIN/EYE:PRLNG/FREQUENT SKIN CONT MAY
CAUSE DEFAT, DRY W/IR RIT & POSS DERM. EYE CONT MAY CAUSE TEAR &
IRRIT. SKIN ABSORPTION:DERM & IRRIT. INGEST:MAY CAUSE GI DISTURB
(SUPP DATA)
Medical Cond Aggravated by Exposure:LIVER AND KIDNEY DISORDERS.
* First Aid Measures *
First Aid:SKIN:WASH WITH SOAP AND WATER. EYES:FLUSH WITH WATER FOR AT
UNCON GIVE ARTF RESP/O*2 AS NEEDED. GET MED ATTN. INGEST: DO NOT
INDUCE VOMIT (ASPIR HAZ). GET MED ATTN.
* Fire Fighting Measures *
Flash Point Method:CC
Lower Limits:1.1%
Upper Limits:6.1%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:POLYMERIZATION MAY TAKE PLACE AT ELEVATED
TEMPERATURE SUCH AS IN FIRE. IF CONTAINED, VIOLENT RUPTURE MAY
RESULT.
* Accidental Release Measures *
Spill Release Procedures:REMOVE SOURCES OF IGNITION. ABSORB SPILL WITH
ABSORBENT MATERIAL SUCH AS VERMICULITE OR SAND.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
IN ORIGINAL CONTAINERS.
Other Precautions:DOT SHIPPING NAME-FLAMMABLE LIQUIDS.
* Physical/Chemical Properties *
HCC:F2
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NIL
Appearance and Odor:GREY LIQUID, SHARP AROMATIC ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT AND DIRECT SUNLIGHT.
Hazardous Decomposition Products:HEATING TO DECOMPOSITION MAY CAUSE
IRRITATING ACRID FUMES.
Conditions to Avoid Polymerization:IF HAZARDOUS POLYMERIZATION OCCURS
WHILE CONTAINED IN CLOSED CONTAINER, VIOLENT RUPTURE MAY RESULT.
* Disposal Considerations *
Waste Disposal Methods:SMALL QTY CAN BE REACTED WITH THE APPROPRIATE
HARDNER TO SOLIDIFY. DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL,
STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE OF A NIOSH/MSHA APPROVED RESP SUCH AS 3M
RESPIRATORY/DUST MASK TO AVOID BREATHING NUISANCE DUST.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:LONG SLEEVES, LOOSE FITTING CLOTHING.
Work Hygienic Practices:WASH EXPOSED AREA WITH SOAP AND WATER AFTER
HANDLING.
Supplemental Safety and Health
APPEAR & ODOR: AS BLANKETS, BOARDS, OR LOOSE FILL INSULATION. MAY HAVE
SLIGHT BINDER ODOR. EXPLO HAZ: FACING OR PACKAGED MATL W/OPEN
FLAME. CHEMS IN VINYL FACINGS OR PLASTIC PACKAGING PRODUCTS THAT DO
NOT PRESENT HEALTH HAZ UNDER NORMAL CONDITIONS MAY BE RELEASED
DURING A FIRE. TOXIC FUMES AND GASES THAT MAY(ING 6)
* Product Identification *
Product ID:FIBERGLASS BLOWING WOOL INSULATION
CAGE:0C7C1
CAGE:0C7C1
* Composition/Information on Ingredients *
Ingred Name:PHENOL (SARA III)(SARA III)
OSHA PEL:5 PPM;SKIN
ACGIH TLV:5 PPM;SKIN
Ingred Name:AMMONIA (SARA III)
Ingred Name:SUPP DATA: RESULT FROM INCOMPLETE COMBUSTION INCLUDE CARBON
MONOXIDE, HYDROGEN CHLORIDE AND LOW-LEVEL CYANIDES. (ING 7
Other REC Limits:N/K]
Ingred Name:EFTS OF OVEREXP: RESEARCHERS FEEL THAT CONTINUING STUDIES
ARE INCONCLUSIVE & FURTHER EVALUATION & RESEARCH IS NEEDED.
Ingred Name:FIBROUS GLASS
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PHENOL FORMALDEHYDE RESIN CURED; (CURED ORGANIC BINDING
MATERIAL)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:FORMALDEHYDE (SARA III)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:FIBERGLASS WOOL IS A POSSIBLE CANCER
HAZ BY INHAL & MAY CAUSE IRRIT OF UPPER RESP TRACT.USE OF RESP SUCH
ADDNL RESP PROT. SKIN: DIRECT CNTCT W/SKIN MAY CAUSE MECH (EFTS OF
OVEREXP)
Explanation of Carcinogenicity:FIBROUS GLASS: IARC SCIENTIFIC
Effects of Overexposure:HLTH HAZ:IRRIT. INHAL: MAY CAUSE MECHANICAL
IRRITATION OF UPPER RESPIRATORY TRACT. BASED ON ANIMAL STUDIES
INVOLVING ARTF IMPLANTATION OR INJECTION OF FINE GLASS FIBERS INTO
THE CHEST, ABDOMINAL CAVIT Y, OR TRACHEA OR LAB ANIMALS, THE IARC
HAS CLASSIFIED MAN-MADE FIBERS AS "POSS CARCIN TO HUMANS."MANY
(ING 7)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:SKIN: DO NOT RUB. WASH W/SOAP & WATER. USE SKIN CREAM TO
SOOTHE IRRIT. WASH CLOTHES SEPARATELY. A SHOWER AFTER WORK IS
RECOMMENDED. IRRIT TYPICALLY WILL NOT PERSIST IF GOOD PERSONAL
HYGIENE HABITS AREFOLLOWED. EYE: FLUSH WITH RUNNING WATER FOR @
INHAL: REMOVE FROM EXPOSURE. INGEST: GET MD IMMEDIATELY .
* Fire Fighting Measures *
Extinguishing Media:WATER, FOAM, DRY CHEMICAL
Fire Fighting Procedures:NONE. WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:FIBERGLASS INSULATION IS A NON-FLAMM
PROD. THE KRAFT & FOIL FACING & PACKAGING MATL WILL BURN, & CAUTION
SHOULD BE USED WHEN WORKING CLOSE TO THE (SUPP DATA)
* Accidental Release Measures *
Spill Release Procedures:AVOID DUST-GENERATING MEANS OF CLEAN-UP. STORE
FACED OR PACKAGED MATERIAL AWAY FROM SOURCES OF IGNITION AND HAVE
FIRE-FIGHTING EQUIPMENT AVAILABLE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
Spec Gravity:2.6 (H*2O=1)
Solubility in Water:NONE
Appearance and Odor:RESILIENT OR SOLID STRUCTURE CNTNG GLASS FIBER AND
BINDING MATLS USED(SUPP DATA
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:DISP OF SCRAP MATERIAL ACCORDING TO FEDERAL,
STATE AND LOCAL REGULATIONS. THIS MATERIAL IS NOT REGULATED UNDER
HAZARDOUS WASTE REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:AIRLINE RESPIRATORS UNLESS SAMPLING DATA ALLOWS
CHEMICAL CARTRIDGE RESPIRATORS.
Ventilation:LOCAL EXHAUST: KEEP CONCENTRATION BELOW TLV.
MECHANICAL(GENERAL): KEEP CONCENTRATION BELOW TLV. SPECIAL:
EXPLOSION PROOF
Other Protective Equipment:EYEWASH SHOWER.
Supplemental Safety and Health
THRESHOLD LIMIT VALUE: NOT ESTABLISHED. 1 MG//M3 RECOMMENDED. N-BUTYL
* Product Identification *
Kit Part:Y
CAGE:0DCP7
CAGE:0DCP7
* Composition/Information on Ingredients *
Ingred Name:1,6-DIISOCYANATOHEXANE (HEXAMETHYLENE DIISOCYANATE)
Fraction by Wt: 1.2%
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:HOMOPOLYMER OF HDI
Ingred Name:N-BUTYL ACETATE (SARA III)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:EXPOSURE ABOVE TLV MAY LEAD TO
BRONCHITIS, BRONCHIAL SPASM & PULMONARY EDEMA.
Effects of Overexposure:EXPOSURE ABOVE TLV MAY LEAD TO BRONCHITIS,
BRONCHIAL SPASM & PULMONARY EDEMA. MAY CAUSE IRRITATION OR
CORROSIVE ACTION ON SKIN OR EYES, INTERNAL TISSUE SENSITIZATION IS
KNOWN.
* First Aid Measures *
First Aid:EYES: FLUSH WITH CLEAN LUKEWARM WATER, OBTAIN MEDICAL
ATTENTION. SKIN: WASH WITH SOAP & WATER. INHALATION: MOVE TO AREA
FREE FROM RISK, ADMINISTER OXYGEN OR ARTIFICIAL RESPIRATION AS
NEEDED, OBTAIN ME DICAL ATTENTION. INGESTION: DO NOT INDUCE
VOMITING, CONSULT PHYSICIAN.
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:1.7
Upper Limits:7.6
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, HIGH EXPANSION
CHEMICAL FOAM.
Fire Fighting Procedures:FULL EMERGENCY EQUIPMENT, SELF CONTAINED
BREATHING APPARATUS & FULL PROTECTIVE CLOTHING SHOULD BE WORN.
SOLVENT VAPOR HEAVIER THAN AIR.
Unusual Fire/Explosion Hazard:HDI VAPORS & HIGHLY TOXIC GASES MAY BE
GENERATED. CLOSED CONTAINERS MAY EXPLODE IN EXTREME HEAT OR BURST
WHEN CONTAMINATED WITH WATER.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE NON-ESSENTIAL PERSONNEL. VENTILATE
AREA & REMOVE SOURCES OF IGNITION. COVER SPILL W/ABSORBENT
MATERIAL. NOTIFY AUTHORITIES; REACT W/DECONTAMINATION SOLUTION FOR
RECOMMENDED.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS AND FLAME.
STORE IN TIGHTLY CLOSED CONTAINERS TO PREVENT MOISTURE
CONTAMINATION.
Other Precautions:GROUND CONTAINERS DURING STORAGE AND TRANSFER
OPERATIONS.
* Physical/Chemical Properties *
Vapor Density:> THAN AIR
Evaporation Rate & Reference:SLOWER (BUTYL ACETATE=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR PALE YELLOW LIQIUD WITH SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
WATER, AMINES, STRONG BASES, ALCOHOLS, METAL COMPOUNDS, SURFACE ACTIVE
MATERIALS.
Stability Condition to Avoid:POLYMERIZATION MAY OCCUR WITH MOISTURE OR
Hazardous Decomposition Products:BY HEAT AND FIRE: CARBON DIOXIDE,
CARBON MONOXIDE, OXIDES OF NITROGEN, TRACES OF HCN OR HDI.
Conditions to Avoid Polymerization:MOISTURE, ISOCYANATE REACTIVE
* Disposal Considerations *
Waste Disposal Methods:IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS. INCINERATION IS THE PREFERRED METHOD. EMPTY CONTAINERS
MUST BE HANDLED WITH CARE DUE TO PRODUCT RESIDUE & FLAMMABLE
SOLVENT VAPORS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH-APPROVED RESPIRATORS DESIGNED TO REMOVE
MIST & ORGANIC SOLVENT VAPORS.
Ventilation:GENERAL DILUTION OR LOCAL EXHAUST.
Other Protective Equipment:PROPER CLOTHING.
Work Hygienic Practices:REMOVE COTAMINATED CLOTHING. WASH HANDS AFTER
USE & BEFORE EATING, DRINKING, OR SMOKING.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL
Fraction by Wt: <5%
Ingred Name:METHANOL (METHYL ALCOHOL), COLUMBIAN SPIRITS
Fraction by Wt: <4%
Ingred Name:DI-SEC-OCTYL PHTHALATE, BIS (2-ETHYLHEXYL) PHTHALATE (DOP),
(SUSPECTED HUMAN CARCINOGEN BY IARC, NTP & ACGIH)
Fraction by Wt: 2.6%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION, REDNESS, TEARING &
BLURRED VISION. SKIN: IRRITATION, DERMATITIS, ITCHING & DARKENING
OF THE SKIN. INHALATION: NASAL/RESPIRATORY IRRITATION, DIZZINESS,
HEADACHE, FATIGUE, & NAUSEA. IN GESTION: GASTROINTESTINAL
IRRITATION, NAUSEA, DIRRHEA & VOMITING.
Explanation of Carcinogenicity:DI-(2-ETHYLHEXYL) PHTHALATE OR DDP IS A
SUSPECTED HUMAN CARCINOGEN.
Effects of Overexposure:EYES: IRRITATION, REDNESS, TEARING & BLURRED
VISION. SKIN: IRRITATION, DERMATITIS, ITCHING & DARKENING OF THE
SKIN. INHALATION: NASAL/RESPERATORY IRRITATION, DIZZINESS,
HEADACHE, FATIGUE & NAUSEA. ING ESTION: GASTROINTESTINAL
IRRITATION, NAUSEA, DIARRHEA & VOMITING. KIDNEY DAMAGE.
* First Aid Measures *
W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR, RESTORE BREATHING,
KEEP PERSON WARM & QUIET & TREAT SYMPTOMATICALLY. INGESTION: DRINK
1 OR 2 G LASSES OF WATER, KEEP PERSON WARM & QUIET. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Lower Limits:2.5%
Extinguishing Media:WATER, FOAM, CO2 & DRY CHEMICAL
Fire Fighting Procedures:NIOSH-APPROVED SELF-CONTAINED BREATHING
APPARATUS. WATER CAN BE USED TO COOL CONTAINERS TO PREVENT BUILD-UP
WHICH MAY RUPTURE CONTAINTERS.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION, VENTILATE,
WEAR MAXIMUM PROTECTIVE EQUIPMENT, AVOID BREATHING VAPORS, CONTAIN
SPILL & ABSORB EXCESS W/DRY INERT MATERIAL.
*Handling and Storage *
Handling and Storage Precautions:COOL WELL VENTILATED AREA. DON'T STORE
OR OPEN FLAME. DON'T FREEZE.
Other Precautions:AVOID BREATHING VAPORS & CONTACT WITH EYES/SKIN.
DON'T TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN. AVOID CONTACT
WITH METALS WHICH ARE NOT BEING TREATED. CONTACT WITH MATERIAL WILL
DARKEN THE META L.
* Physical/Chemical Properties *
Boiling Pt:B.P. Text:SEE SUPP
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHYL ETHER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:CO, CO2 & VARIOUS HYDROCARBONS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE,
AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE UNDER NORMAL USE. IF EXPOSURE IS EXPECTED
TO EXCEED OCCUPATIONAL EXPOSURE LIMITS, USE NIOSH-APPROVED
Ventilation:NO SPECIAL VENTILATION IS NORMALLY NECESSARY. USE
SPECIAL/LOCAL EXHAUST IF HIGH AIRBORNE CONCENTRATIONS OCCUR.
Other Protective Equipment:NO SPECIAL REQUIREMENT. NORMAL WORK
CLOTHING, COVERALL, APRON MAY BE USED TO MINIMIZE SKIN CONTACT.
Work Hygienic Practices:AVOID PROLONGED &/OR REPEATED SKIN CONTACT. DO
NOT WEAR CONTAMINATED CLOTHING. REMOVE & LAUNDER BEFORE REUSE.
Supplemental Safety and Health
WASH THOROUGHLY W/SOAP & WATER AFTER HANDLING.
* Product Identification *
Preparer's Name:REGULATORY, ENVIRONMENTAL
CAGE:0B2U4
* Composition/Information on Ingredients *
Ingred Name:METHACRYLATE POLYMER &/OR ETHYLENE-PROPYLENE COPOLYMER
W/NITROGEN FUNCTIONAL GROUP
Other REC Limits:NONE RECOMMENDED
Ingred Name:ADIPIC ACID; DIISOOCTYL ESTER
Other REC Limits:NONE RECOMMENDED
REFINED PETROLEUM BASESTOCKS CONTAINING ONE OR MORE OF:"
Other REC Limits:NONE RECOMMENDED
Ingred Name:MINERAL OIL
Other REC Limits:NONE RECOMMENDED
Ingred Name:DISTILLATES, SOLVENT-DEWAXED LIGHT PARAFFINIC
Other REC Limits:NONE RECOMMENDED
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATE, SOLVENT DEWAXED
(SEVERE), HEAVY PARAFFINIC
Other REC Limits:NONE RECOMMENDED
Ingred Name:HIGHLY REFINED BASE OIL
Other REC Limits:NONE RECOMMENDED
Ingred Name:MINERAL OIL, SOLVENT REFINED HEAVY PARAFFINIC, SEVERELY
HYDROTREATED (NON-CARCINOGENIC - IARC)
Other REC Limits:NONE RECOMMENDED
Ingred Name:HYDROTREATED MIDDLE PETROLEUM DISTILLATE
Other REC Limits:NONE RECOMMENDED
Ingred Name:MINERAL OIL
Other REC Limits:NONE RECOMMENDED
Ingred Name:SEVERELY HYDROTREATED HYDROCARBON OIL
Other REC Limits:NONE RECOMMENDED
Ingred Name:SEVERELY REFINED PETROLEUM BASESTOCK
Other REC Limits:NONE RECOMMENDED
Ingred Name:SOLVENT REFINED RESIDUM
Other REC Limits:NONE RECOMMENDED
Ingred Name:MINERAL OIL,HYDROTREATED (SEVERE), PETROLEUM DISTILLATE,
HEAVY PARAFFINIC
Other REC Limits:NONE RECOMMENDED
Ingred Name:SOLVENT DEWAXED RESIDUAL OIL (PETROLEUM)
Other REC Limits:NONE RECOMMENDED
Ingred Name:SEVERELY REFINED PETROLEUM BASE STOCK
Other REC Limits:NONE RECOMMENDED
Ingred Name:SOLVENT REFINED HYDROTREATED RESIDUAL OIL
Other REC Limits:NONE RECOMMENDED
Ingred Name:ORGANOMETALLIC ADDITIVES
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-EYE/SKIN:NOT EXPECTED TO CAUSE
PROLONGED OR SIGNIFICANT IRRITATION. RESPIRATORY SYSTEM:UNLIKELY TO
BE HARMFUL W/NORMAL USE. INGESTION:LLOW ORDER TOXICITY, MAY CAUSE
G/I DISTURBANCES. CHRONIC-PRO LONGED &/OR REPEATED SKIN CONTACT MAY
CAUSE DEFATTING, DERMATITIS.
Explanation of Carcinogenicity:USED MOTOR OIL HAVE CAUSED SKIN CANCER
IN LAB ANIMALS IF REPEATEDLY APPLIED W/O WASHING BETWEEN
APPLICATIONS.
Effects of Overexposure:TRANSIENT EYE IRRITATION, REDNESS, TEARING. G/I
DISTURBANCES, DIARRHEA, HEADACHE, DROWSINESS, NAUSEA, VOMITING.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS.
* First Aid Measures *
First Aid:IF IRRITATION PERSISTS OR IS SEVERE, GET MEDICAL ATTENTION.
CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE. INHALED:REMOVE FROM
EXPOSURE. A ID OR RESTORE BREATHING AS NEEDED. INGESTED:DO NOT
INDUCE VOMITING W/O EXPRESS DIRECTION OF MEDICAL PERSONNEL. GIVE
PLENTY OF MILK OR WATER TO DRINK & GET IMMEDIATE MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:COC
Autoignition Temp:Autoignition Temp Text:N/A.
Lower Limits:ND
Upper Limits:ND
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER FOG. DO NOT USE
WATER JETS.
Fire Fighting Procedures:MATERIAL MUST BE PREHEATED TO BURN. DO NOT
ENTER CONFINED SPACE W/O NIOSH APPROVED POSITIVE PRESSURE SCBA &
FULL PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:COOL FIRE EXPOSED CONTAINERS W/WATER.
* Accidental Release Measures *
Spill Release Procedures:USE BEST ENGINEERING PRACTICE DURING CLEAN-UP.
LARGE SPILL:STOP LEAK. DIKE SPILL. RECOVER LIQUID. PREVENT ENTRY
INTO SEWERS, WATERWAYS. SMALL SPILL:NEUTRALIZE. STORE CONTAMINATED
ABSORBENT IN CLOSED C ONTAINER. REPORT SPILL AS REQUIRED.
Neutralizing Agent:MFR GAVE NO INFORMATION OF MSDS.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE. DO NOT STORE NEAR IGNITION SOURCES & STRONG OXIDENTS. MAINTAIN
ADEQUATE VENTILATION. AVOID BREATHING MIST.
Other Precautions:AVOID PROLONGED &/OR REPEATED SKIN CONTACT.
* Physical/Chemical Properties *
HCC:V6
NRC/State Lic Num:NONE
Vapor Density:>1
pH:NA
Evaporation Rate & Reference:<0.1 (BU AC = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, AMBER LIQUID W/MILD PETROLEUM ODOR.
Percent Volatiles by Volume:NEG
Corrosion Rate:UNKNOWNN
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS.
Stability Condition to Avoid:STABLE UNDER AMBIENT TEMPERATURES. AVOID
HEAT & OPEN FLAME.
Hazardous Decomposition Products:SMOKE, FUMES, OXIDES OF CARBON.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF PROPERLY. IF DISCARDED AS SUPPLIED
THE MATERIAL IS CORROSIVE (RCRA). USE MAY CAUSE IT TO EXHIBIT MORE
HAZARDOUS CHARACTERISTICS. MATERIAL MUST BE PACKAGED, LABELED,
TRANSPORTED & DISPOSED I /A/W FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PH: 7.8+0.1. SOL IN H2O: APPRECIABLY SOLUBLE IN H2O.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:NON HAZARDOUS INGREDIENTS.
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGEST: POSSIBLE NAUSEA, UPSET
STOMACH. EYES: POSSIBLE EYE IRRITANT ON DIRECT CONTACT. SKIN/INHAL:
NONE KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NOT KNOWN.
* First Aid Measures *
First Aid:INGEST: SIP WATER OR MILK. IF NAUSEA OR ILLNESS PERSISTS,
CALL YOUR POISON CENTER OR DR. EYES: POUR WARM WATER THRU EYES FOR
CENTER OR DR. SKIN: EXPECT NO PROBLEMS. INHAL: EXCEPT NO PROBLEMS.
* Fire Fighting Measures *
Flash Point:NOT FLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:SMALL SPILLS CAN BE WIPED UP WITH CLOTH, PAPER
OR STANDARD ABSORBENTS(SAND, SAWDUST, VERMICULITE).
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:NO SPECIAL PRECAUTIONS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:N1
pH:SUPDAT
Solubility in Water:SUPP DATA
Appearance and Odor:WHITE OPAQUE VISCOUS LOTION.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:NONE KNOWN.
* Disposal Considerations *
Waste Disposal Methods:CONVENTIONAL SOLID WASTE. DISPOSE OF IN
ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
Control Measures
*
*
Contractor Summary
*
*
Item Description Information
*
Item Manager: S9G
Item Name: LUBRICATING OIL,ENGINE
Unit of Issue: DR
UI Container Qty: 1
Type of Container: DRUM
*
Ingredients
*
Other REC Limits: NONE RECOMMENDED
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: INGESTION & EYES- NOT NORMALLY EXPECTED TO
CAUSE ANY ILL EFFECTS EXCEPT IN VERY SENSITIVE INDIVIDUALS. INHALATION- NO
SIGNIFICANT ADVERSE HEALTH EFFECTS ARE EXPECTED TO OCCUR ON SHORT TERM EXPO
SURE. CHRONIC: SKIN- PROLONGED AND/OR REPEATED CONTACT MAY PRODUCE MILD SKIN
IRRITATION AND INFLAMMATION.
Signs And Symptions Of Overexposure: NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated By Exposure: PERSONNEL WITH PRE-EXISTING SKIN DISORDER
SHOULD AVOID CONTACT WITH THIS MATERIAL.
First Aid: INGESTION- DO NOT INDUCE VOMITING. CONSULT PHYSICIAN. INHALATION-
REMOVE FROM CONTAMINATED AREA. APPLY ARTIFICIAL RESPIRATION. IF UNCONSCIOUS
CONSULT PHYSICIAN. EYES- FLUSH WITH COPIOUS AMOUNTS OF WAT ER. IF IRRITATION
DEVELOPS CONSULT PHYSICIAN. SKIN- WASH WITH SOAP AND WATER. CONSULT PHYSICIAN
IF IRRITATION OR INFLAMMATION DEVELOPS.
*
Handling and Disposal
*
Spill Release Procedures: STOP FLOW. WIPE OR MOP UP OR ABSORB WITH DIATOMACEOUS
EARTH OR OTHER INERT MATERIAL. STORE IN APPROPRIATE COTAINER FOR DISPOSAL.
Neutralizing Agent: NONE
Waste Disposal Methods: IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
Handling And Storage Precautions: AVOID STORAGE NEAR OPEN FLAME OR OTHER
SOURCES OF IGNITION. EXCESSIVE MISTING MAY CAUSE SLIPPERY FLOORS. PROPER
FOOTWEAR REQUIRED.
Other Precautions: WASH OR TAKE SHOWER IF GENERAL CONTACT OCCURS. REMOVE
OIL-SOAKED CLOTHING AND LAUNDER BEFORE REUSE. DISCARD CONTAMINATED LEATHER
*
Fire and Explosion Hazard Information
*
Flash Point Method: COC
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures: DO NOT ENTER ANY ENCLOSED OR CONFINED AREA WITHOUT
PROPER PROTECTIVE EQUIPMENT AND SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard: SLIGHTLY COMBUSTIBLE WHEN HEATED ABOVE FLASH
POINT WILL RELEASE FLAMMABLE VAPORS WHICH CAN BURN IN OPEN OR BE EXPLOSIVE IN
CONFINED SPACES.
*
*
Respiratory Protection: NONE NORMALLY REQUIRED.
Ventilation: SUFFICIENT TO MAINTAIN ATMOSPHERE BELOW TLV LIMIT.
Other Protective Equipment: CHEMICALLY RESISTANT BOOTS AND APRONS RECOMMENDED.
Work Hygienic Practices: WASH HANDS WITH SOAP AND WATER BEFORE EATING,
DRINKING, OR SMOKING.
Supplemental Safety and Health: NONE
*
Physical/Chemical Properties
*
HCC: V6
Vapor Pres: <0.1 MMHG
Vapor Density: > AIR
Evaporation Rate & Reference: LESS THAN ETHER
Solubility in Water: INSOLUBLE
Appearance and Odor: BROWN, OILY LIQUID WITH A PETROLEUM ODOR.
Percent Volatiles by Volume: NIL
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: DO NOT HEAT ABOVE FLASH POINT.
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: CARBON MONOXIDE AND ASPHYXIANTS.
Hazardous Polymerization Indicator: NO
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
Transportation Information
*
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: DR
Container QTY: 1
Type Of Container: DRUM
Additional Data: NONE
*
Detail DOT Information
*
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail IMO Information
*
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
*
Detail IATA Information
*
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail AFI Information
*
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
HAZCOM Label
*
Company Name: LUBRICATING SPECIALTIES CO
Status Code: C
Hazard And Precautions: CHRONIC EFFECTS: SKIN- PROLONGED AND/OR REPEATED
CONTACT MAY PRODUCE MILD SKIN IRRITATION AND INFLAMMATION. AVOID STORAGE NEAR
OPEN FLAME OR OTHER SOURCES OF IGNITION. EXCESSIVE MISTING MAY CAUSE SLIP
PERY FLOORS. PROPER FOOTWEAR REQUIRED. FIRST AID: INGESTION- DO NOT INDUCE
VOMITING. CONSULT PHYSICIAN. INHALATION- REMOVE FROM CONTAMINATED AREA. APPLY
ARTIFICIAL RESPIRATION. IF UNCONSCIOUS CONSULT PHYSICIAN. EYES- FLUSH WITH
COPIOUS AMOUNTS OF WATER. IF IRRITATION DEVELOPS CONSULT PHYSICIAN. SKIN-
WASH WITH SOAP AND WATER. CONSULT PHYSICIAN IF IRRITATION OR INFLAMMATION
DEVELOPS.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED DUST MASK WHEN SAND OR
GROUND CURED PRODUCT.
Ventilation:MECHANICAL,LOCAL TO OUTDOORS
Supplemental Safety and Health
* Product Identification *
Product ID:2
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:ALUMINUM SILICATE (AS NUISANCE DUST OR PARTICULATES NOT
OTHERWISE REGULATED)
Other REC Limits:NONE
Ingred Name:TREATED CLAY
Other REC Limits:NONE
Ingred Name:CALCIUM CARBONATE (MARBLE) (LIMESTONE)
Other REC Limits:NONE
Ingred Name:EPOXY RESIN
Other REC Limits:NONE
Ingred Name:TITANIUM DIOXIDE
Fraction by Wt: 8%.
Other REC Limits:NONE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITANT, SENSITIZER.
Effects of Overexposure:EYE: SEVERE IRRITANT.SKIN: POSSIBLE
IRRITATION AND SENSITIZATION ON REPEATED/PROLONGED EXPOSURE.
INHALATION: FUMES OR DUST FROM CURING OPERATION MAY CAUSE
IRRITATION OF RESPIRATORY SYSTEM. INGE STION: G. I. SYSTEM
IRRITATION POSSIBLE BUT UNLIKELY.
Medical Cond Aggravated by Exposure:ANY PRE-EXISTING ALLERGY OR
SENSITIVITY.
* First Aid Measures *
MIN.CALL MD.SKIN:WASH W/ SOAP & WATER.INHAL:PROVIDE FRESH AIR.IF
BREATH DIFFICULTY PERSIST,CALL MD.INGEST:NOT EXPECTED,IF DOES
OCCUR,CALL MD AND T REAT SYMPTOMATICALLY.
* Fire Fighting Measures *
Flash Point:N/R(PER MFR)
Extinguishing Media:CO*2,FOAM,DRY CHEMICAL
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS
Unusual Fire/Explosion Hazard:N/K(PER MFR)
* Accidental Release Measures *
Spill Release Procedures:NO UNUSUAL PROCEDURE REQUIRED.COLLECT SPILLED
MATERIAL AND PLACE IN METAL CONTAINER FOR DISPOSAL OR SALVAGE.
Neutralizing Agent:NONE
*Handling and Storage *
Handling and Storage Precautions:USE APPROPRIATE PERSONAL PROTECTIVE
DEVICES TO PREVENT CONTACT WITH EYE & SKIN.VENT ANY HEAT CURING
OPERATIONS TO THE OUTDOORS.
* Physical/Chemical Properties *
HCC:N1
Viscosity:PASTE,VISCOUS
Evaporation Rate & Reference:N/R(PER MFR)
Solubility in Water:NIL
Appearance and Odor:WHITE VISCOUS PASTE,EPOXY ODOR.
Percent Volatiles by Volume:0.0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
N/R(PER MFR)
Hazardous Decomposition Products:CO,CO*2,SMOKE PARTICLES W/ TRACE
METALS IF EXPOS TO FLAME.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE WITH DESTRUCTION AND REMOVAL
OTHERWISE,DISPOSE IN ACCORDANCE WITH LOCAL,STATE,FEDERAL AND
CURRENT US EPA REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
FITTED HALF-MASK OR FULL FACEPIECE RESPIRATOR (NIOSH/MSHA) DURING &
AFTER APPLICATION UNLESS AIR MONITORING DEMONSTRATES VAPOR/MIST
LEVELS BELOW APPLICABLE L IMITS. FOLLOW RESPRTR MFR USE DIRECTIONS
Ventilation:KEEP AIR CONCEN BELOW PEL/TLV.REMOVE DECOMP FORMED DURING
WELD/FLAME CUT COATED SURFACES.VENT VAPOR FROM BAKING FINISHES
Other Protective Equipment:EMPLOYEES SHOULD WASH PROMPTLY WHEN SKIN
BECOMES CONTAMINATED. REMOVE CLOTHING THAT BECOMES WET (TO AVOID
FLAMMABILITY).
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE. WASH
HANDS BEFORE EATING, SMOKING, OR USING RESTROOM.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:MIKE LICHATOWICH
* Composition/Information on Ingredients *
Other REC Limits:NONE RECOMMENDED
Ingred Name:GROUND LIMESTONE
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: 7%
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:PROPRIETARY INGREDIENTS (MFR STATES UNIDENTIFIED
INGREDIENTS NOT CONSIDERED HAZARDOUS UNDER FED HAZARD COMM REGS)
Fraction by Wt: BALANCE
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:UNKNOWN Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:SEVERE
IRRITATION.TEARING,REDNESS,BLURRED VISION.
SKIN:REDNESS,IRRITATION.DEFATTING LEADING TO DERMATITIS.
INHAL:NASAL & RESPIRATORY IRRITATION,CNS DEPRESSION
(DIZZINESS,DROWSINESS,WEAKNESS,FATIGU E,CONFUSION)
NAUSEA,VERTIGO,UNCONSCIOUSNESS,ASPHYXIATION. INGEST:GI
IRRITATION,ABDOMINAL PAIN,NAUSEA,VOMITING,DIARRHEA.
Effects of Overexposure:CHRONIC: LIVER, KIDNEY, NS. PROLONGED EXPOSURE
TO SOLVENTS MAY CAUSE CHRONIC HEALTH EFFECTS. TARGET ORGANS: LIVER,
KIDNEYS, NS, SKIN, EYES, RESPIRATORY SYSTEM, CNS.
Medical Cond Aggravated by Exposure:NONE KNOWN
* First Aid Measures *
First Aid:INHAL:MOVE TO FRESH AIR IMMED.IF BREATH STOPPED,GIVE ARTIF
RESP.GET MED AID ASAP. SKIN:IMMED FLUSH W/PLENTY OF WATER.IF MAT'L
PENETRATES CLOTH,IMMED REMOVE CONTAM CLOTH & FLUSH SKIN W/WATER.GET
MED AI D.WASH CLOTH & DECONTAM SHOES BEFORE REUSE. EYE:IMMED FLUSH
GLASSES WATER.DON'T INDUCE VOMITING.SEE DR/POISON CTR IMMED. TREAT
SYMPTOMS.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:0.8
Upper Limits:0.0
Extinguishing Media:DRY CHEMICAL, FOAM, CO2
Fire Fighting Procedures:WEAR SCBA W/FULL FACPIECE (POSITIVE PRESSURE
MODE) & FULL PROTECT CLOTH. USE WATER TO COOL CLOSED CNTNR TO
PREVENT PRESSURE BLDUP/AUTO IGNIT/EXPLOSION W/HEAT.
Unusual Fire/Explosion Hazard:KEEP CNTNR CLSD. VAPOR HEAVIER THAN AIR,
TRAVEL ON GRND TO IGNIT SOURCE. NO HEAT/IGNIT. CLSD CNTNRS MAY
EXPLODE W/HEAT. APP TO HOT SRFC REQUIRE SPCL PRECAUTIONS
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE IGNITION SOURCES. MINIMIZE BREATHING
VAPORS. AVOID SKIN CONTACT. SMALL: ABSORB W/INERT MAT'L
(CLAY,SOIL,COMMERCL ABSORBNT) SHOVEL RECLAIMED LIQ & ABSORBENT INTO
RECOVERY DRUMS. LRG: DIKE. RE CLAIM INTO RECOVERY/SALVAGE DRUMS OR
TANK TRUCK.
*Handling and Storage *
Handling and Storage Precautions:AVOID STORAGE IN HIGH TEMPERATURE
AREAS OR NEAR FIRE OR OPEN FLAME. KEEP CONTAINER CLOSED WHEN NOT IN
USE. AVOID ROUGH HANDLING
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTY. DO NOT WELD OR FLAME CUT ON EMPTY DRUMS. SHOCK FROM DROPPING
MAY SPLIT CONTAINER. CONTACT LENSES SHOULD NOT BE WORN WHEN WORKING
WITH THIS MATE RIAL.
* Physical/Chemical Properties *
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID, ODOR OF SOLVENTS
Corrosion Rate:MINIMAL
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, STRONG ACIDS
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:CAN PRODUCE CARBON MONOXIDE AND/OR
CARBON DIOXIDE.
Conditions to Avoid Polymerization:HIGH TEMPERATURES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL,
(IGNITABLE).
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATORS. NIOSH/MSHA
APPROVED DUST MASK SHOULD BE WORN IF EXCESSIVE AMOUNTS BECOME
AIRBORNE.
Ventilation:NORMAL AMOUNT.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:NON-HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NO INFORMATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . EYES:IMMEDIATELY FLUSH
MD. SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD .
* Fire Fighting Measures *
Extinguishing Media:WATER, DRY POWDER, CO*2.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:WHEN EXCESSIVE FLOCK DUST BECOMES
AIRBORNE, A MODERATE EXPLOSIVE HAZARD DEVELOPS. IGNITABLE. ONCE
IGNITED, BUILDS PRESSURE AT A SUBSTANTIAL RATE.
* Accidental Release Measures *
Spill Release Procedures:NO SPECIAL PRECAUTIONS - SWEEP OR VACUUM.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:NO SPECIAL HANDLING.
Other Precautions:AVOID UNNECESSARY DUSTINESS.
* Physical/Chemical Properties *
Solubility in Water:NON-SOLUBLE
Appearance and Odor:DARK SHADE, NO COLOR; NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:DISPOSER MUST COMPLY W/FEDERAL, STATE OR LOCAL
WASTE DISPOSAL LAWS. NO SPECIAL PRECAUTIONS - INCINERATE OR
LANDFILL.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WELL VENTILATED AREA-RESP NOT REQ. RESTRICTED
VENT-NIOSH CHEMICAL CARTRIDGE MAY BE REQ. IF SPRAYING, MECH
PREFILTER MAY BE REQ. IF TLV ARE EXCEEDED, USE A PROP FITTED
Ventilation:PROVIDE DILUTION/LOCAL EXHAUST VENTILATION TO KEEP
CONCENTRAOF HAZARDOUS SUBSTANCES BELOW EXPOSURE LIMITS STATED.
Other Protective Equipment:AS REQUIRED TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH WITH SOAP AND WATER HANDS/FACE THOROUGHLY
BEFORE EATINGOR WASHING.
Supplemental Safety and Health
NK
* Product Identification *
Preparer's Name:W.A. ELLISON
* Composition/Information on Ingredients *
Ingred Name:MINERAL SPIRITS
Ingred Name:TITANIUM DIOXIDE
Ingred Name:TALC (CONTAINING NO ASBESTOS)
OSHA PEL:2 MG/M3 RDUST
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
Fraction by Wt: NO
OSHA PEL:SEE TABLE Z3
Ingred Name:LEAD (SARA III)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:LEAD CHROMATE
Ingred Name:PROPYLENE GLYCOL METHYL ETHER ACETATE
(VP 2 MM HG @ 2 DEG.C)
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SWALLOWING: CAN CAUSE GASTROINTESTINAL
IRR/NAUSEA/VOMIT. ASPIRATION OF MAT'L MAYCAUSE CHEM PNEUMONITIS.
INHALATION: NOSE/THROAT IRRITA. HIGH CONCENTRATION MAY CAUSE
CENTRAL NERVOUS SYSTEM DEPRESSION CHAR BY
HEADACHES/DIZZINESS/NAUSEA/CONFUSION. EYE: MAY CAUSE EYE IRRITA.
SKIN: MAY CAUSE DEFATTING AND IRRITATION.
Explanation of Carcinogenicity:NTP & IARC-CHROMIUM AND CERTAIN CHROMIUM
COMPOUNDS. IARC-CRYSTALLINE SILICA, LIMITED EVIDENCE
CARCINOGENICITY.
Effects of Overexposure:REPEATED EXPOSURE TO CRYSTALLINE SILICA MAY
CAUSE PNEUMOCONIOSIS. OCCUPATIONALOVEREXPOSURE TO SOLVENTS ASSOC
W/PERM BRAIN/NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY
CONCENTRATING/INHALING CONT MA Y BE HARMFUL/FATAL. INSOLUBLE
CHROMATESMAY CAUSE LUNG CANCER. LEAD-BLOOD DAMAGE &
NERVOUS/URINARY/REPRODUCTIVE SYSTEMS.
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY CONDITIONS
MAY BE AGGRA- VATED BY EXPOSURE TO CRYSTALLINE SILICA. PRE-
EXISTING KIDNEY CONDITIONS MAY BE AGGRAVATED BY EXPOSURES TO
LEAD.
* First Aid Measures *
First Aid:SWALLOWING: DO NOT INDUCE VOMITING/GET MED ATTN. INHALATION:
REMOVE TO FRESH AIRIF BREATHING HAS STOPPED GIVE CPR. GET MED ATTN.
ATTN. SKIN: REMOVE CONTAMINATED CLOTHING.WASH AFFECTED AREA.
OBTAIN MED ATTN IF IRR'N PERSISTS. TREATMENT REQ FOR OVER-
EXPOSURE S/B DIRECTED AT THE CONTROL OF SYMPTOMS AND THE CLINICAL
CONDITIONS.
* Fire Fighting Measures *
Extinguishing Media:USE NFPA CLASS B FIRE EXTINGUISHERS. POLYMER FOAM
IS PREFERRED FOR LARGE FIRES.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS. WATER
TO COOL CONT TO PREVENT POSSIBLE AUTO-IGNITION OR EXPLOSION. IF
WATER IS USED, FOG NOZZLES ARE PREFERABLE.
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT/ELEC
EQUIP/SPARKS/FLAME. CONTAINER MAY EXPLODE WHEN EXPOSED TOHEAT.
OVEREXPOSURE TO DECOMP PRODUCTS MAY CAUSE HEALTH HAZ. OBTAIN MED
ATTN.
* Accidental Release Measures *
Spill Release Procedures:ELIM ALL IGNITION SOURCES. DIKE/CONTAIN SPILL
WITHINERT MAT'L. TRANSFER LIQ'S/ABSORBENT DIKING MAT'LIN COVERED
METAL CONT'S FOR RECOVERY DISPOSAL. USEONLY NON-SPARKING TOOLS.
PREVENT CONTAM OF SEWERS/ STREAMS/GROUNDWATER W/SPILLED MAT'L/USED
ABSORBENT
*Handling and Storage *
Other Precautions:DO NOT BREATHE SANDING DUST OR REUSE EMPTY CONT. DO
NOT TAKE INTERN. CONT'ER S/BGROUNDED AND BONDED TO THE RECEIVING
CONTAINER. DO NOT WELD/BRAZE OR CUT CONT'R.NEVER USE PRESSURE TO
EMPTY. DRUM IS NOTA PRESSURE VESSEL. CLOSE AFTER EA USE.
* Physical/Chemical Properties *
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT AND SOURCES OF
IGNITION.
Hazardous Decomposition Products:BURNING, INCLUD WHEN HEATED BY
WELDING/CUTTING WILL PRODUCE SMOKE/CARBON MONOXIDE-DIOXIDE/OXIDES
OF CHROMIUM AND LEAD.
Conditions to Avoid Polymerization:KEEP AWAY FROM HEAT, SPARKS AND
FLAME.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE ONLY IN EPA PERMITTED FACILITY.
DISPOSEONLY IAW FED/STATE/LOCAL REGS. DO NOT INCINERATE CLOSED
CONTAINERS. OBSERVE PRECAUTIONS FOR DIS- POSAL OF FLAMMABLE
MAT'S. CONTAMINATED ABSORBENT MAY BE DISPOSED IN A HAZARDOUS
WASTE LANDFILL.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
TLV BY VENTILATION, USE A NIOSH/MSHA PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESPIRATOR. WHEN SANDING OR ABRADING FILM, USE A
NIOSH/MSHA DUST/MIST RES PIRATOR.
Ventilation:LOCAL EXHAUST: PREFERABLE. GENERAL EXHAUST: ACCEPTABLE IF
THE EXPOSURE TO HAZARDOUS INGREDIENTS IS KEPT BELOW TLV.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS AFTER USING. DON'T SMOKE.
Supplemental Safety and Health
TRANSFER ONLY TO APPROVED CONTAINERS W/COMPLETE & APPROPRIATE LABELING.
KEEP OUT OF REACH OF CHILDREN. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING & INHALING THE CONTENTS CAN BE HARMFUL OR FATAL.
AVOID BREATHING VAPOR & SPRAY MIST & CONTACT W/SKIN & EYES.
OVEREXPOSURE TO DECOMPOSITION PRODUCTS CAUSE HEALTH HAZARD.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:PROPANE
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:ISOBUTANOL/2-METHYL-1-PROPANOL/ISOBUTYL ALCOHOL
Fraction by Wt: 4%
Ingred Name:ACETONE; DIMETHYL KETONE
Ingred Name:2-BUTANONE (METHYL ETHYL KETONE) (MEK)
Fraction by Wt: 2%
Ingred Name:ETHYL 3-ETHOXYPROPIONATE
Fraction by Wt: 7%
Ingred Name:ISOBUTYL ACETATE
Fraction by Wt: 9%
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE
Fraction by Wt: 4%
OSHA PEL:2 MG/CUM (RESP DUST)
ACGIH TLV:2 MG/CUM (RESP DUST)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF EYES/SKIN/RESPIRATORY
SYSTEM. MAY CAUSE CNS DEPRESSION. OVEREXPOSURE MAY BE FATAL.
PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE ADVERSE EFFECTS TO
LIVER/URINARY/REPRODUCTIVE SYSTEM & PER MANENT BRAIN/NERVOUS SYSTEM
DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: HEADACHE, DIZZINESS, NAUSEA, & LOSS
OF COORDINATION, UNCONSCIOUSNESS & DEATH. EYES/SKIN: REDNESS,
ITCHING OR BURNING SENSATION.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. KEEP WARM
& QUIET. SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/PLENTY OF WATER
UNCONSCIOUS P ERSON. DON'T INDUCE VOMITING. GIVE SEVERAL GLASSES OF
WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:PMCC
Flash Point:<0F
Lower Limits:0.7%
Upper Limits:6%
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIP & SCBA. WATER SPRAY
MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE PREFERABLE.
USE WATER TO COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO
BUILD-UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
*Handling and Storage *
Handling and Storage Precautions:USE ONLY W/ADEQUATE VENTILATION.
CONTENTS ARE FLAMMABLE. KEEP AWAY FROM HEAT, SPARKS & OPEN FLAME.
KEEP AREA VENTILATED.KEEP CONTAINERS TIGHTLY CLOSED
Other Precautions:EXTINGUISH ALL FLAMES/PILOT LIGHTS/HEATERS. TURN OFF
STOVES, ELECTRIC TOOLS & APPLIANCES & OTHER IGNITION SOURCES.
CONSULT NFPA CODE. USE APPROVED BONDING/GROUNDING PROCEDURES. KEEP
CONTAINER CLOSED W HEN NOT IN USE. DON'T TAKE INTERNALLY.
* Physical/Chemical Properties *
Vapor Density:>1
Evaporation Rate & Reference:FASTER THAN ETHER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, HOT SURFACES OR
OTHER IGNITION SOURCES.
Hazardous Decomposition Products:CO2, CO, OXIDES OF METALS IN HAZARDOUS
INGREDIENTS SECTION.
* Disposal Considerations *
Waste Disposal Methods:WASTE MAY BE HAZARDOUS UNDER THE RCRA. TEST
WASTE FOR IGNITABILITY TO DETERMINE THE APPLICABLE EPA HAZARDOUS
WASTE NUMBERS. INCINERATE IN APPROVED FACILITY. DON'T INCINERATE
CLOSED CONTAINER. DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:GENERAL VENTILATION
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
Preparer's Name:JCS
* Composition/Information on Ingredients *
Ingred Name:MAGNESIUM CHROMATE
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.5 MG/M3
Ingred Name:DIPHENYL GUANADINE (DPG)
Fraction by Wt: < 5%
Other REC Limits:NONE SPECIFIED
Ingred Name:MANGANESE DIOXIDE
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG MN/M3
ACGIH TLV:5 MG MN/M3
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION/INGESTION: ALTHOUGH THE
MAIN HAZARD OF MANGANESE COMPOUNDS IS BY BREATHING DUST, INGESTION
SHOULD BE AVOIDED AS A PRECAUTION AGAINST MANGANESE POISONING.
SYMPTOMS OF MANGANESE POISONING ARE WEAKNESS & SLEEPINESS.
PROLONGED EXPOSURE TO HEXAVALENT CHROMIUM COMPOUNDS OVER THE PEL
MAY CAUSE PENETRATING ULCERS...
Effects of Overexposure:...OF THE MUCOUS MEMBRANES OF THE NOSE &
PERFORATION OF THE CARTILAGINOUS NASAL SEPTUM. EYES: STRONG
IRRITANT. CAUSE EYE DAMAGE. SKIN: IRRITATION. MAY CAUSE ALLERGIC
SKIN RASH IN SENSITIZED INDIVIDU ALS. PROLONGED EXPOSURE TO
HEXAVALENT CHROMIUM COMPOUNDS OVER THE PEL MAY CAUSE PAINLESS
PENETRATING ULCERS OF THE SKIN.
* First Aid Measures *
PHYSICIAN.SKIN: WASH WITH SOAP & WATER. IF SYMPTOMS PERSIST,
CONSULT A PHYSICIAN. INHALATION: REMOVE TO FRESH AIR. OBTAIN
MEDICAL ATTENTIO N. INGESTION: CONSULT A PHYSICIAN.
* Fire Fighting Measures *
Flash Point:NOT FLAMMABLE
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER FOG
Fire Fighting Procedures:USE AIR SUPPLIED RESPIRATOR.
Unusual Fire/Explosion Hazard:NONE KNOWN
* Accidental Release Measures *
Spill Release Procedures:SCOOP INTO CONTAINERS. CLEAN-UP RESIDUE WITH
1,1,1-TRICHLOROETHANE.
*Handling and Storage *
Handling and Storage Precautions:WASH THOROUGHLY AFTER HANDLING AND
Other Precautions:THIS PRODUCT CONTAINS A TOXIC CHEMICAL OR CHEMICALS
* Physical/Chemical Properties *
Spec Gravity:1.8
Solubility in Water:NEGLIGIBLE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
EASILY OXIDIZABLE MATERIALS
Hazardous Decomposition Products:OXIDES OF CARBON, CHROMIUM COMPOUNDS
* Disposal Considerations *
COMPLIANCE WITH FEDERAL AND STATE REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA CERTIF RSPRTR. FOR SPECIFIC COND
AIR-LINE RSPRTR IN CONFINED/RESTRICTED VENT AREA, OR
COATING OPERATIONS.
Ventilation:SUFF VENT (VOL/PATTERN)TO KEEP AIR CONTAM CONC BELOW TLV.
Other Protective Equipment:FULL PROTECTIVE CLOTHING. SPARK-PROOF
EQUIPMENT.
Work Hygienic Practices:WASH THOROUGHLY BEFORE EATING, SMOKING OR USING
WASHROOM. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Other REC Limits:NONE SPECIFIED
Ingred Name:DIATOMACEOUS EARTH (MAY CONTAIN CRYSTALLINE SILICA UP TO
Other REC Limits:NONE SPECIFIED
ACGIH TLV:6 MG/M3
Other REC Limits:NONE SPECIFIED
Ingred Name:MAGNESIUM SILICATE (RESPIRABLE QUARTZ <0.1%)
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:TRIMETHYL BENZENE
Other REC Limits:NONE SPECIFIED
Ingred Name:POLYAMIDE
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Health Hazards Acute and Chronic:VAPOR, SPRAY MIST/DUST CAN BE HARMFUL.
IRRIT TO SKIN, MUCOUS MEMBRANES, EYES & RESP SYSTEM. EXCESS INHAL
CAN CAUSE HEADACHE, NAUSEA, DIZZINESS OR ASPHYXIATION.
REPEATED/PROLONGED OCCUPATIONAL OVEREXPO S TO SOLVENTS IS
ASSOCIATED WITH PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE. CAN BE
HARMFUL/FATAL IF SWALLOWED. HARMFUL **
Effects of Overexposure:**HARMFUL IF INHALED OR ABSORBED THROUGH THE
SKIN. OVEREXPOSURE CAN DAMAGE CENTRAL NERVOUS SYSTEM. INGESTION OR
OVEREXPOSURE CAN CAUSE LUNG, KIDNEY, LIVER DAMAGE. SKIN & RESP
SENSITIZATION & ALLERGIC REACTIONS SUCH AS RASH, HIVES OR
ASTHMACAN OCCUR.
Medical Cond Aggravated by Exposure:RESPIRATORY. KIDNEY AND LIVER
DISORDERS. ALLERGIES. SKIN. *NAPHTHA 2.9 G/KG;
* First Aid Measures *
First Aid:OVEREXPOS TO VAPOR, SPRAY MIST OR DUST: PROVIDE FRESH AIR; IF
BREATHING LABORED, GIVE OXYGEN OR ARTIFICIAL RESPIRATION. FOR SKIN
CONTACT, WASH THOROUGHLY W/SOAP & WATER. FOR EYES, FLUSH
ATTENTION. IF SWALLOWED, DRINK 1-2 GLASSES OF WATER TO DILUTE.
DON'T INDUCE VOMITING. CONSULT DR OR POISON CONTROL CTR IMMED.
TREAT SYMPTOMATICALLY.
* Fire Fighting Measures *
Flash Point Method:SCC
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT,
SPARKS AND OPEN FLAME.
* Accidental Release Measures *
Spill Release Procedures:AVOID BREATHING OF VAPOR OR DUST. USE
ABSORBENT CLEANUP MATERIAL OR SWEEP UP. PLACE IN SEPARATE
CONTAINER. KEEP OUT OF PUBLIC SEWERS & WATERWAYS. IF ENTRY IS
THREATENED OR OCCURS, NOTIFY LOCAL AUTHORI TIES. ELIMINATE ALL
SOURCES OF IGNITION.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED, UPRIGHT WHEN
NOT IN USE. STORE IN COOL, DRY, WELL-VENTILATED AREA. AVOID STORAGE
Other Precautions:DO NOT INGEST. AVOID PROLONGED BREATHING OF DUST,
VAPORS OR SPRAY MIST OR CONTACT W/SKIN & EYES. DO NOT WELD OR FLAME
CUT AN EMPTY CNTNR. GRND CNTNRS WHEN POURING. DESTROY CONTAM
LEATHER & ABSORBENT S HOES WHICH CAN'T BE DECONTAMINATED.
* Physical/Chemical Properties *
HCC:F4
Vapor Density:> AIR
Appearance and Odor:LIQUID, SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS, ALKALIES.
Stability Condition to Avoid:HEAT, OPEN FLAME, ARC OR SPARKS.
Hazardous Decomposition Products:BY FIRE, BURNING OR WELDING: CO AND
CO2. NOX. ALDEHYDES.
* Disposal Considerations *
Waste Disposal Methods:IN SEPARATE, CLOSED METAL CONTAINER IN
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NORMALLY REQUIRED.
VENTILATION RATES TO CONDITIONS.
Other Protective Equipment:EYE BATH, WASHING FACILITIES, SAFETY SHOWER.
PROTECTIVE CLOTHING APPROPRIATE FOR THE RISK OF EXPOSURE.
Work Hygienic Practices:EK: ? HMIS:USE GOOD INDUSTRIAL HYGIENE
PRACTICES. MINIMIZE PERSONAL CONTACT. WASH THOROUGHLY AFTER
HANDLING.
Supplemental Safety and Health
DEMAND = MODERATE. EFFECT ON AQUATIC ORGANISMS = LOW. GERMINATION &
PLANT EFFECTS = LOW. WASTE TREATMENT MICROBE EFFECT = LOW. BIOC
ONCENTRATION = LOW. ADVERSE EFFECTS AFTER DILUTION & TREATMENT =
NONE.
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:WATER
Other REC Limits:NONE RECOMMENDED
Ingred Name:FERRIC AMMONIUM ETHYLENEDIAMINETETRAACETIC ACID
Other REC Limits:NONE RECOMMENDED
Ingred Name:ACETIC ACID (CERCLA)
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION:LOW HAZARD FOR RECOMMENDED
EYE:NO SPECIFIC HAZARD KNOWN. MAY CAUSE TRANSIENT
IRRITATION. SKIN:LOW HAZARD FOR RECOMMENDED HANDLING.
INGESTION:EXPECTED TO BE LOW INGESTION HAZARD.
Explanation of Carcinogenicity:IN ADDITION TO THE ABOVE, PRODUCT IS
NEGATIVE W/REGARD TO:ACGIH CANCER, CALIFORNIA CANCER & REPRODUCTIVE
EFFECTS.
Effects of Overexposure:EYE:TRANSIENT IRRITATION.
Medical Cond Aggravated by Exposure:MFR GAVE NO INFORMATION OF MSDS.
* First Aid Measures *
First Aid:IF ANY SYMPTOMS OCCUR, GET IMMEDIATE MEDICAL ATTENTION.
INHALATION:IF SYMPTOMATIC, MOVE TO FRESH AIR. EYE:FLUSH W/PLENTY OF
CLOTHING &LAUNDER BEFORE REUSE. INGESTION:DRINK 1-2 GLASSES OF
WATER. GET IMMEDIATE MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:FLUSH TO SEWER W/LARGE AMOUNTS OF WATER.
OTHERWISE, ABSORB SPILL W/VERMICULITE OR OTHER INERT MATERIAL &
PLACE IN CONTAINER FOR CHEMICAL WASTE. CLEAN SURFACE THOROUGHLY TO
REMOVE RESIDUAL CONTAMINATIO N.
Neutralizing Agent:MFR GAVE NO INFORMATION OF MSDS.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED. KEEP AWAY FROM
INCOMPATIBLE SUBSTANCES.
Other Precautions:USE W/ADEQUATE VENTILATION. WASH THOROUGHLY AFTER
* Physical/Chemical Properties *
HCC:C1
NRC/State Lic Num:NONE
Vapor Density:0.6
pH:5.6
Solubility in Water:COMPLETE
Appearance and Odor:BROWN LIQUID; SLIGHT AMMONIA ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, BASES, SODIUM HYPOCHLORITE(BLEACH)
Stability Condition to Avoid:STABLE UNDER NORMAL CONDITIONS OF USE.
Hazardous Decomposition Products:AMMONIA, SULFUR DIOXIDE
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO LOCAL, STATE AND FEDERAL REGULATIONS. FLUSH TO SEWER WITH LARGE
AMOUNTS OF WATER.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:SUFFICIENT TO MAINTAIN OPERATOR EXPOSURE <APPLICABLE
OCCUPATIONAL EXPOSURE STANDARDS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
USE OF A HAZARDOUS CHEMICAL MAY REQUIRE SUPPLEMENTAL VENTILATION FOR
PROTECTION OF PERSONNEL & FOR CONTROLLING FIRE/EXPLOSION HAZARD. A
QUALIFIED INDEPENDENT TESTING COMPANY CAN DETERMINE IF EXISTING
CONCENTRATIONS ARE W/IN ESTABLISHED RECOMMENDED/PERMISSIBLE
EXPOSURE LEVELS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:DIETHYLENE GLYCOL BUTYL ETHER ACETATE, ETHANOL, 2-
(2-BUTOXYETHOXY), BUTYL CARBITOL ACETATE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MODERATE IRRITATION. SKIN:
SLIGHT IRRITATION. INHALATION: NASAL & RESPIRATORY IRRITATION, CNS
EFFECTS, DEATH. INGESTION: GI IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DIZZINESS, WEAKNESS, FATIGUE,
NAUSEA, HEADACHE, UNCONSCIOUSNESS, VOMITING, DIARRHEA, REDNESS,
TEARING.
* First Aid Measures *
INHALATION: REMOVE TO FRESH AIR. INGESTION: IF CONSCIOUS GIVE 2
GLASSES OF WATER & INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
* Fire Fighting Measures *
Extinguishing Media:DRY CHEMICAL, CO2, ALCOHOL FOAM.
Fire Fighting Procedures:WEAR A SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:VAPORS ARE >AIR & MAY TRAVEL ALONG GROUND
TO DISTANT IGNITION SOURCE.
* Accidental Release Measures *
Spill Release Procedures:REMOVE IGNITION SOURCES. ABSORB MATERIAL
W/VERMICULITE/FLOOR ABSORBENT. DISPOSE OF CONTAMINATED MATERIALS
*Handling and Storage *
Handling and Storage Precautions:FOR FLAMMABLE/COMBUSTIBLE PRODUCTS,
COMBUSTIBLE LIQUIDS CODE.
Other Precautions:CONTAINERS MAY BE HAZARDOUS WHEN EMPTIED, SINCE
EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES WHICH CAN GENERATE
VAPORS W/IN FLAMMABLE LIMITS.
* Physical/Chemical Properties *
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE LIQUID/SEMI-SOLID INK W/MILD ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES/MINERAL ACIDS.
Stability Condition to Avoid:HEAT, FLAME & OTHER IGNITION SOURCES.
Hazardous Decomposition Products:CO & CO2.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. IT'S THE RESPONSIBILITY OF THE GENERATOR OF THE WASTE
TO DETERMINE WHETHER THE WASTE GENERATED MEETS THE FEDERAL/STATE
HAZARDOUS WASTE CRITERIA.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NO SPECIAL REQUIREMENTS UNDER ORDINARY
CONDITIONS OF USE AND WITH ADEQUATE VENTILATION. WEAR NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:GENERAL VENTILATION SUFFICIENT TO KEEP AIRBORNE
CONCENTRATION BELOW CURRENT EXPOSURE LIMITS .
Other Protective Equipment:NO SPECIAL EQUIPMENT REQUIRED.
Work Hygienic Practices:GOOD PERSONAL HYGIENE PRACTICES SHOULD ALWAYS
BE FOLLOWED.
Supplemental Safety and Health
FIRST AID PROC: POIS CNTRL CNTR FOR ASSIST. DO NOT INDUCE VOMIT/GIVE
ANYTHING BY MOUTH TO AN UNCON PERSON. WASTE DISP METH: ANY GOVT
APPRVD WASTE DISP FACILITY. USE OF THESE METHS IS SUBJECT TO USER C
OMPLIANCE W/APPLIC LAWS & REGS & CONSIDERATION OF PROD CHARACT AT
TIME OF DISP. DISP I/A/W FED, ST,& LOC REGS .
* Product Identification *
* Composition/Information on Ingredients *
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:HEXANEDIOIC ACID MONOETHYL ESTER, LITHIUM SALT
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PENTANEDIOIC ACID MONOMETHYL ESTER, LITHIUM SALT
OSHA PEL:N/K
ACGIH TLV:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:1-DECENE, HOMOPOLYMER, HYDROGENATED
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SOLVENT DEWAXED RESIDUAL OIL (PETROLEUM)
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED (SEVERE)
LIGHT NAPHTHENIC;(DISTILLATES (PETROLEUM), HYDROTREATED(ING 9)
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:ING 8: LIGHT NAPHTHENIC)
Ingred Name:OCTYLATED N-PHENYL-1-NAPHTHYLAMINE; (1-NAPHTHALENEAMINE,
N-PHENYL-AR-(1,1,3,3-TETRAMETHYLBUTYL)).
Fraction by Wt: <3.0%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ALKYL AMIDES
OSHA PEL:N/K
ACGIH TLV:N/K .
Ingred Name:FIRE FIGHT PROC: TO FLUSH SPILLS AWAY FROM EXPOS. PREVENT
Ingred Name:OTHER PRECAUTIONS: CASE OF ACCIDENTAL OR ROAD SPILL NOTIFY
Ingred Name:LITHIUM HYDROXIDE
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SLIGHT SKIN IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE LISTED BY MANUFACTURER.
* First Aid Measures *
CALL PHYS. SKIN: WASH CONT AREAS W/SOAP & WATER. HIGH PRESS
ACCIDENTAL INJECTION THRU SKIN REQS IMMED MED ATTN FOR POSS
INCISION. IRRIGATI ON &/OR DEBRIDEMENT. INHAL: REMOVE FROMEXPOS.
SUPPORT BRTHG (GIVE OXYGEN/ARTF RESP) . INGEST: IF >1/2 LITER
(PINT) INGEST, IMMED GIVE 1-2 GLASSES OF WATER & CALL PHYS, HOSP
EMER ROOM/ (SUPDAT)
* Fire Fighting Measures *
Flash Point Method:COC
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL AND WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER/FOAM MAY CAUSE FROTHING. USE WATER TO KEEP FIRE EXPOS
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:ABSORB ON FIRE RETARDANT TREATED SAWDUST,
DIATOMACEOUS EARTH, ETC. SHOVEL UP AND DISPOSE AT AN APPROPRIATE
WASTE DISPOSAL FACILITY IN ACCORDANCE WITH CURRENT APPLICABLE LAWS
AND REGULATIONS, AND PRODU CT CHARACTERISTICS AT TIME OF DISPOSAL.
Neutralizing Agent:NONE LISTED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:NO SPECIAL PRECAUTIONS REQUIRED.
Other Precautions:ENVIRON IMPACT: REPORT SPILLS AS REQD TO APPROP AUTH.
U.S. COAST GUARD REGS REQ IMMED REPORTING OF SPILLS THAT COULD
REACH ANY WATERWAY INCL INTERMITTENT DRY CREEKS. REPORT SPILL TO
* Physical/Chemical Properties *
HCC:V6
Solubility in Water:NEGLIGIBLE
Appearance and Odor:RED GREASE, MILD ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:EXTREME HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:PROD IS SUITABLE FOR BURNING IN AN ENCLOSED,
CNTRLD BURNER FOR FUEL VALUE OR DISP BY SUPERVISED INCIN. SUCH
BURNING MAY BE LIMITED PURSUANT TO RCRA. IN ADDN, PROD IS SUITABLE
FOR PROCESSING BY AN APPR VD RECYCLING FACILITY/CAN BE DISP OF
AT(SUPDAT)
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF EXPOSURE EXCEEDS TLV, USE NIOSH APPROVED
RESPIRATOR TO PREVENT OVEREXPOSURE.
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO MEET TLV
REQUIREMENTS.
Other Protective Equipment:EYE WASH FOUNTAIN AND SAFETY SHOWERS
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:DISTILLATE (PETROLEUM),HYDROTREATED MIDDLE;ON MSDS MFR
SUMPLY NOTED AS "PETROLEUM HYDROCARBON" FOR ABOVE CAS NO.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NON-IRRITATING ON EYE CONTACT. MAY
CAUSE SLIGHT SKIN IRRITATION. INHALATION OF VAPORS OR OIL MIST MAY
CAUSE MILD IRRITATION OF UPPER RESPIRATORY TRACT. INGESTION MAY
RESULT IN VOMITING. AVOID ASPIRATI ON.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:EYES-NONE NOTED. SKIN-IRRITATION.
INGESTION-VOMITING. INHALATION-UPPER RESPIRATORY IRRITATION.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN AND RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
* First Aid Measures *
WASH WITH SOAP & WATER. INHALED-REMOVE TO FRESH AIR. GIVE OXYGEN IF
NEEDED. INGESTED-DO NOT INDUCE VOMITING! GET MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:COC
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL/CARBON DIOXIDE. DON'T
USE DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE
REIGNITED.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL FIRE FIGHTER'S PROTECTIVE GEAR. USE WATER TO COOL FIRE EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:MATERIAL WILL NOT BURN UNLESS PREHEATED.
* Accidental Release Measures *
Spill Release Procedures:SOAK UP WITH ABSORBENT SUCH AS CLAY, SAND OR
OTHER SUITABLE MATERIAL. DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS FOR OIL RESIDUE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT, OPEN FLAMES AND
OXIDIZING MATERIALS.
Other Precautions:NONE.
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:INSOLUBLE
Appearance and Odor:YELLOW-GREEN LIQUID; SLIGHT HYDROCARBON ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS.
Stability Condition to Avoid:HEAT, OPEN FLAMES, OXIDIZING MATERIALS.
Hazardous Decomposition Products:CAN PRODUCE CARBON MONOXIDE & OTHER
UNIDENTIFIED ORGANIC COMPOUNDS.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:PLACE IN APPROPRIATE DISPOSAL FACILITY IN
COMPLIANCE WITH LOCAL REGULATIONS.
| 1 | gloves_mandatory |
Subsets and Splits
No saved queries yet
Save your SQL queries to embed, download, and access them later. Queries will appear here once saved.