text
stringlengths 595
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:43509-0, CELLULOSE NITRATE, 11 WT % N VISCOSITY (SUPDAT)
CAGE:21076
CAGE:21076
============= Composition/Information on Ingredients =============
Ingred Name:2-PROPANOL
CAS:67-63-0
RTECS #:NT8050000
= Wt:30.
OSHA PEL:980 MG/M3;400 PPM
ACGIH TLV:983 MG/M3;400 PPM
ACGIH STEL:1230 MG/M3;500 PPM
Ingred Name:CELLULOSE, NITRATE
CAS:9004-70-0
RTECS #:QW0970000
= Wt:11.
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL,RAT) >5 GM/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY BE HARMFUL BY INHALATION,
INGESTION, OR SKIN ABSORPTION. CAUSES SEVERE EYE IRRITATION. CAUSES
SKIN IRRITATION. MATERIAL IS IRRITATING TO MUCOUS MEMBRANES AND
UPPER RESPIRATORY TRACT. CAN CA USE CNS DEPRESSION. PROLONGED
EXPOSURE CAN CAUSE: NAUSEA, HEADACHE AND VOMITING, NARCOTIC EFFECT.
PROLONGED OR REPEATED EXPOSURE TO SKIN CAUSES DEFATTING AND
DERMATITIS. CHRONIC: TARGET ORGAN(S): NERV ES, KIDNEYS, LIVER. TO
THE BEST OF OUR KNOWLEDGE, CHEMICAL PHYSICAL, & TOXICOLOGICAL
PROPERTIES HAVE NOT BEEN THOROUGHLY INVESTIGATED.
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT
LEAST 15 MINUTES. ASSURE ADEQUATE FLUSHING OF EYES BY SEPARATING
THE EYELIDS WITH FINGERS. SKIN: IMMEDIATELY WASH WITH SOAP &
COPIOUS AMOUN TS OF WATER. INHAL: REMOVE TO FRESH AIR. IF NOT
BREATHING GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT,
GIVE OXYGEN. INGESTION: WASH OUT MOUTH WITH WATER PROVIDED PERSON
IS CONSCIOUS. CALL A PHYSICIAN. REMOVE AND WASH CONTAMINATED
CLOTHING PROMPTLY.
===================== Fire Fighting Measures =====================
Flash Point:=11.7C, 53.F
53F,11C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER OR APPROPRIATE
FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . PREVENT CONT W/SKIN & EYES. USE WATER SPRAY TO COOL
FIRE-EXPOSED CONTAINERS. FLAMMABLE SOLID.
Unusual Fire/Explosion Hazard:VAPOR MAY TRAVEL CONSIDERABLE DISTANCE TO
SOURCE OF IGNITION & FLASH BACK. CONTAINER EXPLOSION MAY OCCUR
UNDER FIRE CONDITIONS. WARNING: THIS MATERIAL IS CLASSIFIED AS AN
EXPLOSIVE WHEN DRY. FIRE FIGH TING SHOULD BE DONE FROM A REMOTE
POSITION.
================== Accidental Release Measures ==================
Spill Release Procedures:SHUT OFF ALL SOURCES OF IGNITION. EVACUATE
ABSORB ON SAND OR VERMICULITE AND PLACE IN CLOSED CONTAINERS FOR
DISPOSAL. USE NONSPARKING TOOLS. VENTILATE AREA AND WASH SPILL
SITE AFTER MATERIAL PICKUP IS COMPLETE.
======================Handling and Storage ======================
Handling and Storage Precautions:ADDNL INFO: WARNING: DANGEROUS WHEN
DRY. 2-PROPANOL CONTENT MUST BE MAINTAINED >25 WT % FOR STORAGE.
MATL CNTNG <25% ALCOHOL IS AN EXPLOSIVE. CHECK 2-PROPANOL CONTENT
PERIODICALLY AND ADD MORE ALCOHOL AS NEC. DO NOT GET IN EYES, ON
SKIN, ON CLOTHING. DO NOT BREATHE VAPOR.
Other Precautions:SEVERE EYE IRRITANT. KEEP TIGHTLY CLOSED. KEEP AWAY
FROM HEAT, SPARKS, AND OPEN FLAME. DO NOT ALLOW MATL TO BECOME DRY.
STORE IN A COOL DRY PLACE. FLAMM(US). HIGHLY FLAMM(EU). IRRITANT.
IRRITATING TO EYES, RESP SYS & SKIN. RISK OF SERIOUS DMG TO EYES.
KEEP AWAY FROM SOURCES OF IGNIT - NO SMOKING. (S UPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
MFR TRADE NAME/PART NO: 5-6 SEC (WITH 30% IPA). OTHER PREC: IN CASE OF
CONT W/EYES, RINSE IMMED W/PLENTY OF WATER & SEEK MED ADVICE. WEAR
SUITABLE PROTECTIVE CLOTHING. KEEP WET WITH: 2-PROPANOL. TOX I NFO:
CHEM SUBSTANCES (RTECS) DATA IS PRESENTED HERE. SEE ACTUAL ENTRY IN
RTECS FOR COMPLETE INFORMATION.
================== Physical/Chemical Properties ==================
Boiling Pt:=83.C, 181.4F
Spec Gravity:1.230
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, ACIDS, BASES, ACID ANHYDRIDES, HALOGENS, ALUMINUM.
Stability Condition to Avoid:DO NOT HEAT OVER: 60 DEGREES C.
Hazardous Decomposition Products:TOXIC FUMES OF: CARBON MONOXIDE,
CARBON DIOXIDE, NITROGEN OXIDES.
=================== Toxicological Information===================
Toxicological Information:ACUTE: MAY BE HARMFUL BY INHAL, INGEST/SKIN
ABSORP. CAUSES SEV EYE IRRIT. CAUSES SKIN IRRIT. MATL IS IRRIT TO
MUC MEMB & UPPER RESP TRACT. CAN CAUSE CNS DEPRESS. PRLNGD EXPOS
CAN CAUSE: NAUS, HDCH & V OMIT, NARCOTIC EFT. PRLNGED/RPTD EXPOSTO
SKIN CAUSES DEFAT & DERM. CHRONIC: TARGET ORGAN(S): NERVES,
KIDNEYS, LIVER. TO BEST OF OUR KNOWLEDGE, CHEM, PHYSICAL, & TOX
PROPERTIES HAVE NOT BEEN THOROUGHLY INVESTIGATED. ORL-RAT LD50:>5
GM/KG - TXAPA9 33,159,1975. ORAL-MUS LD50:>5 GM/KG - TXAPA9
33,159,1975. ONLY SELECTED REGISTRY OF TOXIC EFTS OF (SUPDAT)
===================== Ecological Information =====================
Ecological:DATA NOT YET AVAILABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER BUT EXERT EXTRA CARE IGNITING AS THIS
MATERIAL IS HIGHLY FLAMMABLE. OBSERVE ALL FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGULATI ONS.
=================== MSDS Transport Information ===================
Transport Information:CONTACT ALDRICH CHEMICAL COMPANY FOR
TRANSPORTATION INFORMATION.
===================== Regulatory Information =====================
Federal Regulatory Information:EUROPEAN INFO: CAUTION: SUBSTANCE NOT
YET FULLY TESTED. HIGHLY FLAMM. IRRITANT. R 36/37/38 IRRITATANT. R
36/37/38 IRRITATING TO EYES, RESP SYS & SKIN. R 41 RISK OF SERIOUS
DMG TO EYES. HIGHLY FLAMM. S 16 KEEP AWAY FROM SOURCES OF IGNIT -
NO SMKNG. S 26 IN CASE OF CONT W/EYES, RINSE IMMED W/PLENTY OF
WATER & SEEK MED ADVICE. S 36 WEAR SUITABLE PROTECTIVE CLOTHING. S
48 KEEP WET WITH: 2-PROPANOL. TL V & SOURCE FOR 2-PROPANOL
(ISOPROPYL ALCOHOL): ACGIH TLV-TWA: 400 PPM (983 MG/M3): STEL: 500
PPM (12 25 MG/M3). REVIEWS, STDS, & REGS: DEL-MAK NOHS 1974: HAZD
T0186: (OTHER INFO)
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CARI-D-TECT
CAGE:0F2Y9
CAGE:0F2Y9
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE & CHRONIC:NONE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:NOT APPLICABLE. INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO
FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP) .
EYES:IMMEDIATELY FLUSH W/POTABLE WATER FOR MINIMUM OF 15 MINUTES,
SEEK ASSI STANCE FROM MD . SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER.
CALL MD .
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB MATERIAL WITH PAPER TOWEL & DISPOSE OF
IN PROPER MANNER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NEEDED. NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NOT NEEDED.
Other Protective Equipment:NONE.
Work Hygienic Practices:NONE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:<1 (WATER=1)
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:100% SOLUBLE
Appearance and Odor:DARK LIQUID, NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:NO SPECIFIC METHOD REQUIRED. DISPOSAL MUST BE
I/A/W FEDERAL, STATE & LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ELVAX, 3179-2
Preparer's Name:T E SCHROER
CAGE:18873
CAGE:18873
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE-VINYL ACETATE COPOLYMER
> Wt:99.7
Ingred Name:VINYL ACETATE AEL DUPONT: 10 PPM - 8 & 12 HR TWA. WHERE
GOVERNMENTALLY IMPOSED OCCUP EXPOS LIMITS WHICH ARE LOWER THAN AEL
ARE IN EFT, SUCH LIMITS SHALL TAKE PRECEDENCE.
CAS:108-05-4
RTECS #:AK0875000
< Wt:.3
ACGIH TLV:35 MG/M3;10 PPM
ACGIH STEL:53 MG/M3;15 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL,RAT) 2920 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:BEFORE USING "ELVAX" RESINS, READ
BROCHURES ON SAFE HNDLG PROCEDURES. ACUTE: INGEST: THE ORAL LD-50
IN RATS USING 1 TYPE OF "ELVAX" IS IN EXCESS OF 1000 MILLIGRAMS PER
KILOGRAM OF BODY WT. 2 WEEK META BOLIC TESTS WITH DOGS & RATS
SHOWED THAT NO SIGNIFICANT AMOUNT OF POLYMER WAS RETAINED BY
ANIMALS. 90-DAY FEEDING STUDIES IN RATS SHOWED THAT "ELVAX" RESINS
HAVE LOW TOX. SLIGHT LIVER EFTS WERE SEEN I N ANIMALS FED DIETS
CNTNG 10% "ELVAX"; NO EFTS WERE SEEN W/DIETS CNTNG 5% "ELVAX".
OVERALL, NO IMPORTANT BODY SYSTEMS OR ORGAN DYSFUNCTION OCCURRED AT
EITHER DOSE LEVEL. SKIN: NO DATA AVAILABLE. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:VINYL ACETATE. IARC MONOGRAPHS; VOL 63,
PG 443, 1995: GROUP 2B.
Effects of Overexposure:HLTH HAZS: HOWEVER, BASED ON EXPERIENCE W/HNDLG
THESE POLYMERS, NO UNUSUAL DERM HAZ IS EXPECTED FROM ROUTINE HNDLG.
MOLTEN POLYMER CONTACTING SKIN WILL CAUSE THERMAL BURNS. EYE:
MECHANICAL IRRITATION. INHAL: POLYMER IS NOT RESPIRABLE AS
MARKETED. AT PROCESSING TEMPS ABOVE 204 DEGREES C, FUMES IRRITATING
TO EYES, NOSE, AND THROAT MAY BE PRODUCED. EXPOSURE MAY RESULT IN
REDNESS, TEARING, AND ITCHING IN THE EYES TOGETHER WITH SORENESS
IN THE NOSE AND THROAT WITH COUGHING.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTF RESP. IF
BRTHG IS DFCLT, GIVE OXYG. CALL PHYS. SKIN CONT: CMPD IS NOT LIKELY
TO BE HAZ BY SKIN CONT BUT CLEANSING SKIN AFTER USE IS ADVISABLE.
IF MO LTEN MATL GET ON SKIN, COOL RAPIDLY W/COLD WATER. DO NOT
ATTEMPT TO REMOVE MATL FROM SKIN. OBTAIN MEDICAL TREATMENT FOR
THERMAL BURN. EYE CONT: IMMEDIATELY FLUSH W/PLENTY OF WATER FOR AT
LST 15 MINUTE S. CALL PHYSICIAN. INGEST: NO SPECIFIC INTERVENTION
IS INDICATED AS CMPD IS NOT LIKELY TO BE HAZ BY INGEST. CONSULT
PHYSICIAN IF NECESSARY.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:=260.C, 500.F
Extinguishing Media:WATER, FOAM, DRY CHEMICAL, CO*2.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:SOLID POLYMER CAN BE COMBUSTED ONLY
W/DFCLTY. ELECTROSTATIC CHARGE CAN POTNTLY BUILD UP WHEN POURING
PELLETS. GROUNDING OF EQUIP IS REC. HAZ COMBUST PRODS: COMPLETE
COMBUST GIVE CO*2 & WATER. INCOMPLE TE COMBUST GIVES, IN ADDN, CO &
HYDROCARBON OXIDATION PRODS INCL ORGANIC ACIDS, ALDEHYDES, AND
ALCOHOLS.
================== Accidental Release Measures ==================
Spill Release Procedures:SAFEGUARDS (PERSONNEL). NOTE: REVIEW FIRE
FIGHTING MEASURES & HANDLING (PERSONNEL) SECTION BEFORE PROCEEDING
WITH CLEAN-UP. USE APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT DURING
CLEAN-UP. SPILL CLEAN U P: SHOVEL OR SWEEP UP.
======================Handling and Storage ======================
Handling and Storage Precautions:SEE FIRST AID AND PERSONAL PROTECTIVE
EQUIPMENT SECTIONS.
Other Precautions:STORE IN A COOL, DRY PLACE. KEEP CONTAINER CLOSED TO
PREVENT CONTAMINATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH APPRVD AIR PURIFYING RESP W/ORG VAP
CARTRIDGE WITH DUST/MIST FILTER MAY BE PERMISSIBLE UNDER CERTAIN
CIRCUMSTANCES WHERE AIRBORNE CONCS ARE EXPECTED TO EXCEED EXPOS
LIMITS. USE NIOSH APPRVD PO SITIVE PRESS AIR SUPPLIED RESP IF THERE
IS ANY POTNTL FOR UNCONTROLLED RELEASE, EXPOS LEVELS ARE NOT
KNOWN/ANY OTHER CIRCUMSTANCES WHERE NIOSH APPRVD (SUPDAT)
Ventilation:LOC VENT MUST BE USED OVER PROCESSING EQUIP TO MAINTAIN
VINYL ACETATE CONCS IN AIR BELOW PEL. USE STATIC CTLS. STATIC
CHARGES CAN BUILD UP (SUPDAT)
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER . IF
THERE IS POTNTL CONT WITH HOT/MOLTEN MATERIAL, WEAR HEAT RESISTANT
CLOTHING AND FOOTWEAR.
Supplemental Safety and Health
RESP PROT: NIOSH APPRVD AIR PURIFYING RESPS MAY NOT PROVIDE ADEQ PROT.
VENT: AND IGNITE DUST/SOLV LADEN ATM. TOX INFO: RATS BUT NOT IN
MICE. RESEARCH ON MECHANISM OF NASAL TUMOR INDUCTION IN RATS SUGG
ESTS THAT LEVELS @ WHICH HUMANS ARE LIKELY TO BE EXPOS ARE BELOW
THRESHOLD FOR EFTS THAT CONTRIBUTE TO (OTHER INFO)
================== Physical/Chemical Properties ==================
Spec Gravity:0.93-0.97
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TRANSLUCENT TO WHITE PELLETS. MILD ESTER-LIKE ODOR.
Percent Volatiles by Volume:NEGLIGIBLE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE OR CAN REACT WITH STRONG ACIDS, OXIDIZING AGENTS.
Stability Condition to Avoid:TEMPERATURES ABOVE 230 DEGREES C FOR SHORT
RESIDENCE TIMES. TEMPERATURES ABOVE 204 DEGREES C FOR LONG
RESIDENCE TIMES.
Hazardous Decomposition Products:VINYL ACETATE, ACETIC ACID, CARBON
MONOXIDE AND HYDROCARBON OXIDATION PRODUCTS INCLUDING ORGANIC
ACIDS, ALDEHYDES AND ALCOHOLS.
=================== Toxicological Information===================
Toxicological Information:ANIMAL DATA: VINYL ACETATE. INHAL 4 HR LC50:
4000 PPM IN RATS. SKIN ABSORP LD50: 2335 MG/KG IN RABBITS. ORAL
LD50: 2920 MG/KG IN RATS. VINYL ACETATE IS SLIGHT SKIN & SEV EYE
IRRITANT, & WEAK SKIN SENS ITIZER IN ANIMALS. NO EFTS FROM RPTD
EXPOS TO VINYL ACETATE BY INHAL WERE OBSERVED @ 100 PPM IN RATS.
EXPOS TO HIGHER CONCS OF VINYL ACETATE BY INHAL CAUSED EYE IRRIT &
LACRIMATION, REDUCED WT GAIN, & IRRIT OF RESP TRACT W/BRTHG
DFCLTY. EFTS OBSERVED IN RATS & MICE EXPO BY INHAL TO 200 & 600 PPM
FOR 2 YRS INCL REDUCED BODY WT, & PATHOLOGICAL CHANGES IN NOSE &
RESP TRACT. NASAL CAVITY TUMORS WERE O BSERVED IN (SUPDAT)
===================== Ecological Information =====================
Ecological:AQUATIC TOXICITY: NO INFORMATION IS AVAILABLE. TOXICITY IS
EXPECTED TO BE LOW BASED ON INSOLUBILITY IN WATER.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREFERRED OPTIONS FOR DISP ARE (1) RECYCLING,
(2) INCINERATION W/ENERGY RECOVERY, AND (3) LANDFILL. HIGH FUEL
VALUE OF PROD MAKES OPTION 2 VERY DESIRABLE FOR MATL THAT CANNOT BE
RECYCLED. TREATMENT, S TORAGE, TRANSPORTATION, & DISP MUST BE I/A/W
APPLIC FEDERAL, STATE/PROVINCIAL, & LOCAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:SHIPPING INFORMATION. DOT HAZARD CLASS: NOT
REGULATED.
===================== Regulatory Information =====================
SARA Title III Information:VINYL ACETATE: DISCLOSURE AS A TOXIC
CHEMICAL IS REQUIRED UNDER SECTION 313 OF TITLE III OF THE
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 AND 40 CFR
PART 372.
Federal Regulatory Information:U.S. FEDERAL REGULATIONS. TSCA INVENTORY
STATUS: IN COMPLIANCE WITH TSCA INVENTORY REQUIREMENTS FOR
COMMERCIAL PURPOSES.
State Regulatory Information:STATE RIGHT-TO-KNOW. NO SUBSTANCES ON
STATE HAZ SUBSTANCES LIST, FOR STATES INDICATED BELOW, ARE USED IN
MFR OF PRODS ON THIS MSDS, W/EXCEPTIONS INDICATED. SUBSTANCED ON
PENNSYLVANIA HAZ SUBSTANCES LI ST PRESENT @ CONC OF 1%/MORE (0.01%
FOR SPEC HAZ SUBSTANCE) - NONE KNOWN. WARNING - SUBSTANCES KNOWN TO
STATE OF CALIFORNIA TO CAUSE CANCER, BIRTH DEFECTS/OTHER REPRO HARM
- NONE KNOWN. SUBSTANCES ON NEW JERSEY WORKPLACE HAZ SUBSTANCE
LIST PRESENT @ CONC OF 1%/MORE (0.1% FOR SUBSTANCES IDENTIFIED AS
CARCINS, MUTAGENS/TERATOGENS) - NONE KNOWN.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HP-10
CAGE:62530
CAGE:62530
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL-2-CYANOACRYLATE *95-4*
CAS:7085-85-0
Fraction by Wt: 60-100%
Ingred Name:POLYMETHYLMETHACRYLATE, PLEXIGLAS (IARC CANCER
REVIEW-GROUP 2B) *95-4*
CAS:9011-14-7
RTECS #:TR0400000
Fraction by Wt: 10-30%
Ingred Name:HYDROQUINONE; 1,4-DIHYDROXYBENZENE; 1,4-BENZENEDIOL
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: 0-1%
OSHA PEL:2 MG/CUM
ACGIH TLV:2 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(MOUSE): 12.22 CC/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN:
PROLONGED/REPEATED CONTACT MAY CAUSE DERMATITIS IN SENSITIVE
INDIVIDUALS. INHALATION: IRRITATION OF MUCOUS MEMBRANES.
PROLONGED/REPEATED EXPOSURE MAY PRODUCE ALLERGIC REACTIONS
W/ASTHMA-LIKE SYMPTOMS IN SENSITIVE INDIVIDUALS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:TEARING, IRRITATION, COUGHING, WEEPING OF EYES,
DOUBLE VISION, LIPS MAY BECOME STUCK TOGETHER.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN, EYE &
RESPIRATORY DISORDERS.
======================= First Aid Measures =======================
First Aid:EYES: MOVE TO FRESH AIR. FLUSH W/WATER. ADHESIVE WILL
DISASSOCIATE OVER TIME, USUALLY W/IN SEVERAL HOURS. SKIN: IMMERSE
IN WARM WATER, SOAPY WATER. PEEL/ROLL APART. INHALATION: REMOVE TO
FRESH AIR. IN GESTION: APPLY COPIOUS AMOUNTS OF WARM WATER &
ENCOURAGE WETTING/PRESSURE FROM SALIVA INSIDE MOUTH. PEEL/ROLL
(DON'T PULL) LIPS APART. (SEE SUPPLEMENTAL DATA)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:176F
Extinguishing Media:WATER/DRY CHEMICAL EXTINGUISHER
Fire Fighting Procedures:FUMES MAY BE IRRITATING IF NOT BURNING &
WATER/DRY CHEMICAL EXTINGUISHER.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:POLYMERIZE W/WATER. SOLID MATERIAL MAY BE
SCRAPED FROM SURFACE.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID MOISTURE, DIRECT UV-SUNLIGHT &
DON'T STORE >25C. KEEP CONTAINERS CLOSED TIGHTLY WHEN NOT IN USE.
STORE IN COOL, DRY PLACE. IDEAL STORAGE: 5-10C.
Other Precautions:AVOID BREATHING VAPOR, CONTACT W/SKIN/EYES. DON'T
STORE AT -5C WHICH FREEZES PRODUCT TO USELESS STATE. PRODUCT NOT
DAMAGED BY FREEZING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH-APPROVED ORGANIC VAPOR CANISTER MAY BE
USED TO MAINTAIN PROPER VAPOR CONCENTRATION BELOW TLV.
Ventilation:LOCAL EXHAUST: TO MAINTAIN VAPOR CONCENTRATION BELOW TLV.
MECHANICAL (GENERAL): LARGE AMOUNTS USED TO 2PPM.
Other Protective Equipment:RUBBER APRON
Supplemental Safety and Health
FIRST AID CONT'D: IT'S ALMOST IMPOSSIBLE TO SWALLOW CYANOACRYLATE AS
ADHESIVE SOLIDIFIES UPON CONTACT W/SALIVA & MAY ADHERE TO INSIDE OF
MOUTH. SALIVA WILL LIFT ADHESIVE IN 1-2 DAYS, AVOID SWALLOWING
ADHESIVE AFTER DETACHMENT. OBTAIN MEDICAL ATTENTION IN ALL CASES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:149F
Vapor Pres:1
Spec Gravity:1.05
Solubility in Water:INSOLUBLE
Appearance and Odor:TRANSPARENT WATER-WHITE TO STRAW COLORED LIQUID
W/STIMULATIVE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, ALCOHOL, AMINES, ALKALINE MATERIALS.
Stability Condition to Avoid:TEMP >122F, MOISTURE & DIRECT UV-SUNLIGHT.
Hazardous Decomposition Products:CO & CO2.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE SOLID COMBUSTIBLE WASTE/DUMP AS
CHEMICAL WASTE IAW/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SUPERLOCK BOLTLOCK 2262
CAGE:HO121
CAGE:16059
CAGE:HO121
============= Composition/Information on Ingredients =============
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE ING 3
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: SEVERE IRRITATION/BURNS.
SKIN: SEVERE IRRITATION/BURNS. DMT CAN BE ABSORBED THROUGH SKIN.
INHAL: VAPOR AND/OR MIST RESPIRATORY IRRITANT. INGEST: NO DATA.
CHRONIC: SACCHARIN IS POSSIBLE CA RCIN IF INGESTED.
Explanation of Carcinogenicity:SACCHARIN: IARC MONO, SUPP, VOL 7, PG
334, 1987: GRP 2B. ANTIC TO BE A CARCIN (NTP) .
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:EYES: HOLD EYE OPEN AND FLUSH WITH COPIOUS QTY OF WATER FOR
AT LEAST 15 MINUTES. SKIN: WASH WITH SOAP AND WATER. INHAL: MOVE TO
FRESH AIR. GIVE OXYGEN/ARTF RESP; CONSULT PHYS. INGEST: DO NOT
INDUCE VO MIT. IF CONSCIOUS, GIVE WARM WATER; CONSULT PHYS.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:212F,100C
Extinguishing Media:WATER, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:IN LARGE QTY COULD UNDERGO VIOLENT
POLYMERIZATION GENERATING SIGNIFICANT HEAT AND PRESSURE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROT CLTHG. DIKE AND ABSORB WITH INERT
MATL SUCH AS NU-DRI; DISCARD IN SUITABLE CONTAINER. CAUTION:
ABSORBED PRODUCT MAY POLYMERIZE GENERATING HEAT; MAY BE NECESSARY
TO VENT CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM CHILDREN. AVOID SKIN &
EYE CONT. SPRAY/MIST PRESENTS INHAL HAZ. STORE IN A COOL, DRY
LOCATION AWAY FROM DIRECT SUNLIGHT.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY NEEDED. WITH SPRAY/MIST,
NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC VAPORS SHOULD BE WORN.
Ventilation:LOCAL EXHAUST FOR WORKER COMFORT.
Other Protective Equipment:OTHER CLOTHING AS REQUIRED TO PROTECT SKIN.
EMERGENCY EYE BATH & DELUGE SHOWER MEETING ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PH (5% BY WT IN WATER):7-8.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>400F,>204C
Vapor Pres:0.01@68F
Vapor Density:1.01
Spec Gravity:1.1-1.15
pH:SUPDAT
Evaporation Rate & Reference:LOW(BUTYL ACETATE=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:THICK RED LIQUID WITH PLEASANT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID STRONG REDUCING AGENTS.
Stability Condition to Avoid:TEMPS ABOVE 176F (80C), METALS AND THEIR
SALTS.
Hazardous Decomposition Products:AT HIGH TEMPS: CO, CO*2, AND OTHER
ORGANICS.
Conditions to Avoid Polymerization:TEMPS ABOVE 176F(80C), METALS AND
THEIR SALTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:REMOVE ABSORBED MATERIAL TO WASTE DISPOSAL
FACILITY OPERATING IN COMPLIANCE WITH STATE, LOCAL AND FEDERAL
REGULATIONS. DISCARD CONTAMD CLTHG.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:240302 WELL-PREP VINYL WASH PART B
Kit Part:Y
CAGE:0HDZ7
CAGE:60378
CAGE:0HDZ7
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL(IARC-GROUP 3) *98-2*
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 13-15%
Other REC Limits:400 PPM
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
Ingred Name:PHOSPHORIC ACID *98-2*
CAS:7664-38-2
RTECS #:TB6300000
Fraction by Wt: 2.99%
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/CUM
ACGIH TLV:1 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: CORROSIVE TO NOSE, THROAT
& MUCOUS MEMBRANES. BRONCHITIS, PULMONARY EDEMA & CHEMICAL
PNEUMONITIS MAY OCCUR. SEVERE IRRITATION & TISSUE DAMAGE/DEATH.
EYES: CORROSIVE, IRRITATING & PERMAMENT INJURY. SKIN: CORROSIVE,
IRRITATION, BURNS/DESTROY TISSUE & DEATH. INGESTION: CORROSIVE TO
THE MOUTH & THROAT. (SUPP)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, COUGHING, CHEST PAIN, DIFFICULTY IN
BREATHING, BLINDNESS, BURNS, ABDOMINAL PAIN, NAUSEA, VOMITING,
COLLAPSE.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS, EYE
PROBLEMS/IMPAIRED LIVER, KIDNEY/RESPIRATORY FUNCTION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR IF NEEDED. EYES:
FLUSH W/LOTS OF RUNNING WATER FOR 30 MINS. SKIN: FLUSH W/LOTS OF
RUNNING WATER FOR 30 MINS. INGESTION: DON'T INDUCE VOMITING. IF
CONSCIOUS, G IVE LOTS OF WATER/MILK. DON'T GIVE ANYTHING BY MOUTH
TO AN UNCONSCIOUS/CONVULSING PERSON. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:53F
Lower Limits:2
Upper Limits:12.7
Extinguishing Media:ALCOHOL FOAM, DRY CHEMICAL, CO2, WATER FOG.
Fire Fighting Procedures:DON'T USE DIRECT WATER STREAM. WEAR SCBA/AIR
MASKS. CLOSED CONTAINERS SHOULD BE KEPT COOL W/WATER SPRAY.
Unusual Fire/Explosion Hazard:THIS LIQUID EVAPORATES & FORMS INVISIBLE
VAPORS WHICH SPREAD EASILY & CAN BE IGNITED.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES, VENTILATE CONFINED
SPACES, KEEP PEOPLE AWAY. KEEP OUT OF OPEN BODIES OF WATER, STORM
DRAINS & SEWERS. DIKE & ABSORB W/INERT MATERIAL & PUT INTO
CONTAINERS(COVER W/WATER)FOR RE COVERY/DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE. DON'T HANDLE/STORE NEAR HEAT, FLAMES, SPARKS & STRONG
OXIDIZERS.
Other Precautions:DON'T TAKE INTERNALLY. AVOID PROLONGED
CONTACT/INHALATION. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN SPRAY APPLYING, WEAR RESPIRATORY PROTECTIVE
EQUIPMENT. RESPIRATORY PROTECTION MUST BE AN AIR SUPPLIED
MASK/HOOD/APPROVED RESPIRATOR.
Ventilation:WHEN GENERAL IS SUFFICIENT, USE LOCAL EXHAUST BELOW TLV.
MECHANICAL EXHAUST EQUIPMENT MUST BE EXPLOSION PROOF WHEN USING
Other Protective Equipment:CAP & IMPERMEABLE APRON.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
HLTH HZRD CONT'D: INGESTION-SEVERE BURNS IN TISSUES. LARGE AMOUNTS OF
CAN CAUSE DEATH.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:181F
Vapor Pres:33
Vapor Density:>1
Evaporation Rate & Reference:FASTER THAN BU AC
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIQUID W/MEDICINAL ALCOHOL ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALIS, OXIDIZING/REDUCING AGENTS, ACTIVE METALS.
Stability Condition to Avoid:SOURCES OF IGNITION, HIGH TEMPS, FLAMES,
SPARKS & DIRECT HEATING.
Hazardous Decomposition Products:MAY LIBERATE PHOSPHOROUS OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE/LANDFILL IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T DUMP INTO LAKES, STREAMS/OTHER WATER SUPPLY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DE-SOLV-IT,CABLE CLEANER
CAGE:4T581
CAGE:4T581
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL (EXPOSURE REGULATED AS 'OIL MIST')
CAS:8012-95-1
RTECS #:PY8030000
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3/10 STEL;9192
Ingred Name:ORANGE OIL
Other REC Limits:NONE SPECIFIED
OSHA PEL:NOT ESTABLISHED.
ACGIH TLV:NOT ESTABLISHED.
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL,?) >17,750 MG/KG (>16 ML/KG)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE- EYES/SKIN: MAY CAUSE
IRRITATION. INHALATION: NO TOXIC MANIFESTATIONS. INGESTION:
ASPIRATION HAZARD. MAY BE HARMFUL OR FATAL. CHRONIC- NONE KNOWN.
Effects of Overexposure:MAY CAUSE EYE AND SKIN IRRITATION. NO TOXIC
MANIFESTATIONS BY INHALATION. ASPIRATION HAZARD. MAY BE HARMFUL OR
FATAL.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS
(DERMATITIS) MAY BE MORE SUSCEPTIBLE TO THIS MATERIAL.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. SKIN:WASH WITH
SOAP & WATER. EYE:FLUSH WITH WATER FOR 15 MINUTES, HOLDING EYELIDS
OPEN. INHALED:REMOVE TO FRESH AIR & PROVIDE OXYGEN/CPR IF NEEDED.
ORAL:DO N OT INDUCE VOMITING. IF VOMITING OCCURS,KEEP HEAD BELOW
HIPS DUE TO ASPIRATION HAZARD. CALL PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:205F,96C
Autoignition Temp:Autoignition Temp Text:675F
Extinguishing Media:WATER SPRAY, CO2, FOAM/DRY CHEMICAL. WATER SPRAY
MAY BE USED TO KEEP FIRE EXPOSED CONTAINERS COOL & FLUSH SPILLS
AWAY.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. DO NOT USE STREAM OF
WATER. THIS MAY SCATTER BURNING LIQUID.
Unusual Fire/Explosion Hazard:MAY PRODUCE DENSE, BLACK SMOKE. STAY
UPWIND OF A FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH DRY SAND OR OIL ABSORBENT.
TRANSFER INTO A SUITABLE CONTAINER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE-STORE IN COOL, VENTILATED
PLACE AWAY FROM HEAT, FLAME & SOURCES OF IGNITION.
Other Precautions:WASH THOROUGHLY AFTER HANDLING. AVOID CONTACT WITH
EYES, SKIN AND CLOTHING. AVOID BREATHING VAPORS OR MISTS. KEEP OUT
OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. WEAR SELF CONTAINED
BREATHING APPARATUS IN HIGH VAPOR AREAS.
Ventilation:ADEQUATE
Other Protective Equipment:LAB APRON OR LAB COAT, EYE WASH STATION &
SAFETY SHOWER.
Work Hygienic Practices:PRACTICE GOOD HYGIENIC PROCEDURE. WASH
THOROUGHLY BEFORE EATING OR DRINKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:367F,186C
Vapor Pres:8 @ 20 C
Vapor Density:4.5
Spec Gravity:0.801
Evaporation Rate & Reference:0.06 (N-BUTYL ACETATE=1)
Solubility in Water:< 0.001 %
Appearance and Odor:A LIQUID OF ORANGE COLOR - CITRUS ODOR
Percent Volatiles by Volume:97
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES
Hazardous Decomposition Products:CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:PRODUCT IS BIODEGRADABLE. LANDFILL OR
INCINERATION AT ANY APPROVED FACILITY CONFORMING TO LOCAL, STATE
AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CHLOROTHEME 617X2
CAGE:1FE17
CAGE:1FE17
============= Composition/Information on Ingredients =============
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Other REC Limits:350 PPM (CL)
OSHA PEL:350 PPM/450 STEL
ACGIH TLV:350 PPM/450STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RATS LD50 = 8.6-15.0 G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: ANAESTHETIC EFFECTS MAY
OCCUR AT 500-1000 PPM. INGESTION: HARMFUL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: INTOXICATION, UNCONSCIOUSNESS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH THOROUGHLY W/WATER FOR 10-15 MINS. SKIN: REMOVE
SOILED OR SATURATED CLOTHING. WASH AFFECTED W/AMOUNTS OF WATER.
INHALATION: TAKE TO FRESH AIR, IF NECESSARY, APPLY ARTIFICIAL
RESPIRATION. K EEP VICTIM WARM. CALL DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:6%
Upper Limits:16.7%
Extinguishing Media:WATER SPRAY, FOAM
Fire Fighting Procedures:VAPORS ARE HEAVIER THAN AIR.
Unusual Fire/Explosion Hazard:USE COMPRESSED AIR BREATHING APPARATUS.
================== Accidental Release Measures ==================
Spill Release Procedures:PROVIDE GOOD VENTILATION. ABSORB W/LIQUID
BINDING MATERIALS, COLLECT & DISPOSE OF AS SPECIAL WASTE. THIS
SUBSTANCE IS A WATER POLLUTANT. LARGE SPILLS, DAM SPILL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP SEPARATE FROM UNSTABLE ALUMINUM PRODUCTS. KEEP SEPARATE
FROM HOT SURFACES BECAUSE OF DANGER.
Other Precautions:AVOID CONTACT W/EYES. KEEP AWAY FROM FOOD/BEVERAGES.
WORK ONLY IN WELL VENTILATED ROOM TO AVOID INTOXICATING SIDE
EFFECTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FILTER TYPE A DUST/MIST
Ventilation:LOCAL EXHAUST/MECHANICAL
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:74.1C
Melt/Freeze Pt:M.P/F.P Text:-33C
Vapor Pres:133
Evaporation Rate & Reference:(BU AC = 1): 2.4
Solubility in Water:1.3
Appearance and Odor:LIQUID; CLEAR; CHARACTERISTIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
DON'T STORE IN ALUMINUM CONTAINERS.
Stability Condition to Avoid:AQUEOUS, ACIDIC MEDIA, SODIUM HYDROXIDE &
ALUMINUMM. SOURCES OF IGNITION, HOT SURFACES.
Hazardous Decomposition Products:HCL, PHOSGENE, CHLORINE, FLAMMABLE
GASES.
==================== Disposal Considerations ====================
Waste Disposal Methods:RECYCLING PLANT, SPECIAL WASTE PLANT
(INCINERATION, LANDFILL).
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CEFAZOLIN SODIUM
Preparer's Name:CHRISTINA J. BARRINGTON
CAGE:EO410
CAGE:EO410
CAGE:39832
CAGE:0K706
============= Composition/Information on Ingredients =============
Ingred Name:CEFAZOLIN SODIUM
CAS:25953-19-9
Fraction by Wt: 100.0%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE, SKIN AND RESPIRATORY IRRITATION
MAY OCCUR. NOTE: PRODUCT INTENDED FOR THERAPEUTIC USE ONLY WHEN
PRESCRIBED BY A PHYSICIAN. CHRONIC: HYPERSENSITIVITY REACTIONS
RANGING FROM MILD TO LIFE-THREATENIN G MAY OCCUR.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION, SKIN IRRITATION, RESPIRATORY
IRRITATION
Medical Cond Aggravated by Exposure:PRE-EXISITNG SKIN AND RESPIRATORY
CONDITIONS MAY BE ADVERSELY AFFECTED BY EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE PERSON TO FRESH AIR IMMEDIATELY. GIVE
ARTIFICIAL RESPIRATION AND CPR IF REQUIRED. SEEK MEDICAL ATTENTION.
INGESTION: FLUSH MOUTH WITH WATER IMMEDIATELY. SEEK MEDICAL
ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING IMMEDIATELY. FLUSH
AREA WITH WATER. SEEK MEDICAL ATTENTION. EYES: IMMEDIATELY FLUSH
WITH WATER FOR AT LEAST 15 MINUTES. SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CARBON DIOXIE OR FOAM AS
APPRORPIATE
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND
FULL FACE-PIECE SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:WHEN HEATED TO DECOMPOSITION IT EMITS
TOXIC FUMES. COMBUSTIBLE POWDER.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR RECOMMENDED PERSONAL PROTECTIVE
EQUIPMENT. USE ABSORBENT TOWELS OR BOOMS TO CLEAN-UP SPILL. WIPE
SURFACES CLEAN AND WASH WITH SOAP AND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:WHEN HANDLING PHARMACEUTICAL PRODUCTS,
AVOID ALL CONTACT AND INHALATION OF DUST, FUMES, MISTS AND/OR VAPOR
ASSOCIATED WITH THE PRODUCT.
Other Precautions:FOR ADVERSE DRUG REACTION INFORMATION, CALL
708-317-5937.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WITH SATISFACTORY VENTILATION, RESPIRATORY
PROTECTION NOT USUALLY REQUIRED.
Ventilation:GENERAL ROOM VENTILATION IS USUALLY SATISFACTORY, USE LOCAL
EXHAUST VENTIALTION WHEN NECESSARY.
Other Protective Equipment:DISPOSABLE GARMENTS IF DIRECT SKIN CONTACT
IS ANTICIPATED.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
POTENTIAL ADVERSE REACTIONS FROM PRESCRIBED DOSES AND OVERDOSES ARE
DESCRIBED MORE FULLY IN THE PACKAGE INSERT. OCCUPATIONL EXPOSURE
HAS NOT BEEN FULLY INVESTIGATED.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NOT GIVEN
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:NOT GIVEN
Spec Gravity:NOT GIVEN
pH:4.5-7
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:SOLUBLE
Appearance and Odor:YELLOWISH-WHITE ODORLESS POWDER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:PROTECT FROM FREEZING.FACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF NOX AND SOX.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:98-26 RED IRON OXIDE SPRUCE 473
CAGE:59581
CAGE:59581
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 14-16%
Other REC Limits:100 PPM
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VM&P NAPHTHA (LIGROINE)
CAS:8032-32-4
RTECS #:OI6180000
Other REC Limits:STEL 400 PPM
OSHA PEL:300 PPM/400 STEL
ACGIH TLV:300 PPM; 9192
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 11-14%
Other REC Limits:100 PPM
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HEXANE (N-HEXANE)
CAS:110-54-3
RTECS #:MN9275000
Other REC Limits:50 PPM
OSHA PEL:500 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ACETONE (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 24-27%
Other REC Limits:590 MG/CUM
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9192
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
CAS:75-28-5
RTECS #:TZ4300000
Other REC Limits:1000 PPM
OSHA PEL:1800 MG/CUM
ACGIH TLV:1000 PPM
Ingred Name:ALUMINUM (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 1-3%
OSHA PEL:15MG/M3 DUST/5 FUME
ACGIH TLV:10MG/M3 DUST; 9192
Ingred Name:MINERAL SPIRITS
Ingred Name:ETHYL ALCOHOL (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
Other REC Limits:1900 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9192
Ingred Name:MODIFIED SHORT OIL ALKYD
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITANT. SKIN:
DEFATTING/DERMATITIS/SCALY/REDNESS/DRY/ABSORPTION. INHALATION:
RESPIRATORY SYSTEM IRRITATION/HEADACHE/DIZZINESS/NAUSEA/POSSIBLE
UNCONSCIOUSNESS/ASPHYXIATION/NOSE/THROAT IRRITATION
/NAUSEA/VOMITING/INCOORDINATION/DROWSINESS. INGESTION:
STUPER/INTOXICATION/COMA.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: CARDIAC EFFECTS/CNS
DEPRESSION/PERIPHERAL POLYNEUROPATHY/COMA/NARCOSIS/CUMULATIVE
NARCOTIC EFFECTS/ACIDOSIS/HARMFUL/FATAL. INGESTION:
BLINDNESS/FATAL. EYES: PERMANENT LOSS OF VISION. SKIN: FISSURED
DERMATITIS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING STOPS, BEGIN
ARTIFICIAL RESPIRATION. EYES: FLUSH W/WATER FOR 15 MINUTES. SKIN:
WASH W/SOAP & WATER. INGESTION: UNLIKELY FROM AN AEROSOL CAN.
OBTAIN MEDICA L ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:-10F
Lower Limits:0.70%
Upper Limits:9.5%
Extinguishing Media:USE CO2, DRY CHEMICAL & FOAM
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS
KEEP FIRE-EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:EXPOSURE TO HEAT OR SUN MAY CAUSE
BURSTING.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. WIPE UP W/INERT MATERIALS &
PLACE IN APPROPRIATE CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE >120F. EXPOSURE TO HEAT OR
PROLONGED EXPOSURE TO SUN MAY CAUSE BURSTING.
Other Precautions:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING
VAPORS & INHALING CONTENTS CAN BE HARMFUL OR FATAL. USE ONLY AS
DIRECTED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A SELF-CONTAINED BREATHING APPARATUS
REQUIRED FOR CONCENTRATIONS >TLV.
Ventilation:ADEQUATE VENTILATION IS SUFFICIENT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Pres:40 PSIA
Vapor Density:>AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:PAINT W/SOLVENT ODOR
Percent Volatiles by Volume: 85%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & STRONG OXIDIZING AGENTS
Stability Condition to Avoid:TEMPS >120F, SPARKS, PILOT LIGHT, OPEN
FLAME, SOURCES OF IGNITION, HEAT & SUNLIGHT
Hazardous Decomposition Products:CO2 & CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T INCINERATE AEROSOL CAN, DISPOSE OF IN
ACCORDANCE W/LOCAL STATE & FEDERAL REGULATIONS. DON'T PLACE AEROSOL
CANS IN HOME COMPACTOR. DON'T PUNCTURE.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: RICH LUX PATIO AND DECK ENAMEL, 077203
Cage: 85519
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 85519
Box: 600
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHALATION: IRRITATION OF RESPIRATORY TRACT. PROLONGED
INHALATION MAY LEAD TO MUCOUS MEMBRANE IRRITATION DROWSINESS, AND/OR
LIGHT-HEADEDNESS, HEADACHE, NAUSEA. SKIN: IRRITATION OF SKIN. PROLONGED OR R
EPEATED CONTACT CAN CAUSE DERMATITIS. EYE: IRRITATION OF EYES. PROLONGED OR
REPEATED CONTACT CAN (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: CREATE BLURRED VISION, CORNEAL
INJURY. INGESTION: AMOUNTS INGESTED INCIDENTAL TO CONSUMER AND INDUSTRIAL
HANDLING ARE NOT LIKELY TO CAUSE INJURY; HOWEVER, INGESTION OF LARGER AMOUNTS
COULD C AUSE SERIOUS INJURY.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL: REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
HAVE TRAINED PERSON GIVE OXYGEN IF NEC. GET EMER MED ATTN. SKIN: WASH OFF
QUICKLY W/PLENTY OF H*2O, THEN SOAP & H*2O; REMOVE CONTAMD CLTH G. WASH
CONTAMD CLTHG BEFORE REUSE. EYE: FLUSH IMMED W/LRG AMTS OF H*2O, ESP UNDER
LIDS, FOR AT LEAST 15 MIN. OBTAIN EMER MEDICAL TREATMENT. INGEST: IF
SWALLOWED, OBTAIN MEDICAL TREATMENT IMMEDIATELY.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: COLLECT IN CONTAINER FOR DISPOSAL, ACCORDING TO
HEALTH AND ENVIRONMENTAL REGULATIONS. CLEAN UP WITH WATER BEFORE ALLOWING TO
DRY.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
Handling And Storage Precautions: STORE BELOW 100 DEGREE F. KEEP FROM FREEZING.
Other Precautions: DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NON-FLAMMABLE
Lower Limits: SEE INGRED
Extinguishing Media: DRY CHEMICAL OR FOAM.
Fire Fighting Procedures: NON-FLAMMABLE. WATER MAY BE USED TO COOL AND PROTECT
EXPOSED CONTAINERS. USE NIOSH APPROVED SCBA & FULL PROTECTIVE EQUIPMENT
(FP N).
Unusual Fire/Explosion Hazard: CLOSED CONTAINERS MAY BURST IF EXPOSED TO
EXTREME HEAT OR FIRE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW APPLICABLE
STANDARDS. WHERE RESPIRATORY PROTECTION IS REQUIRED, USE ONLY NIOSH APPROVED
RESPIRATORS IN ACCORDANCE WITH OSHA STANDARD 29 CFR 1910.134.
Ventilation: MAINTAIN ADEQUATE VENTILATION TO ENSURE AIR ENTRY DURING
APPLICATION AND DRYING TO PREVENT BUILD-UP OF VAPORS.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N). SKIN CREAM (IF NEEDED).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >212F,>100C
Vapor Pres: SEE INGRED
Spec Gravity: 1.13-1.37(FP N)
Evaporation Rate & Reference: SLOWER THAN ETHYL ETHER
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume: 64-68
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: ELEVATED TEMPERATURES. CONTACT WITH OXIDIZING
AGENTS.
Materials To Avoid: OXIDIZERS, ACIDS, BASES, AMINES.
Hazardous Decomposition Products: IF INVOLVED IN FIRE (FROM OTHER SOURCES)
COULD CONCEIVABLY RESULT IN RELEASE OF CARBON DIOXIDE AND CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: RICH LUX PATIO AND DECK ENAMEL, 077203
Cage: 85519
Company Name: M A BRUDER & SONS INC
Street: 600 REED RD
PO Box: 600
Zipcode: 19008
Label Required IND: Y
Date Of Label Review: 03/10/1997
Status Code: C
Label Date: 03/10/1997
Origination Code: G
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: INHALATION: IRRITATION OF RESPIRATORY TRACT.
PROLONGED INHALATION MAY LEAD TO MUCOUS MEMBRANE IRRITATION DROWSINESS,
AND/OR LIGHT-HEADEDNESS, HEADACHE, NAUSEA. SKIN: IRRITATION OF SKIN. PROLONG
ED OR REPEATED CONTACT CAN CAUSE DERMATITIS. EYE: IRRITATION OF EYES.
PROLONGED OR REPEATED CONTACT CAN CREATE BLURRED VISION, CORNEAL INJURY.
INGESTION: AMOUNTS INGESTED INCIDENTAL TO CONSUMER AND IN DUSTRIAL HANDLING
ARE NOT LIKELY TO CAUSE INJURY; HOWEVER, INGESTION OF LARGER AMOUNTS COULD
CAUSE SERIOUS INJURY. CHRONIC: NONE SPECIFIED BY MANUFACTURER.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:111A153 SEVEN STAR RUSTIC TONES LATEX SOLID STAIN
CAGE:ACEHA
CAGE:ACEHA
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 22.3%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9495
Ingred Name:NEPHELINE SYENITE
CAS:37244-96-5
Fraction by Wt: 14.7%
OSHA PEL:N/K
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:CLAY (KAOLIN); (ALUMINUM SILICATE)
CAS:1332-58-7
RTECS #:GF1670500
Fraction by Wt: 4.8%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9495
Ingred Name:SILICA, AMORPHOUS-DIATOMACEOUS EARTH; (DIATOMACEOUS SILICA)
CAS:61790-53-2
RTECS #:HL8600000
Fraction by Wt: 2.4%
OSHA PEL:20 MPPCF; Z-3
ACGIH TLV:10 MG/M3 TDUST; 9495
Ingred Name:IRON (III) OXIDE; (RED IRON OXIDE)
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 6.2%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5MG(FE)/M3FUME,B2;95
Ingred Name:IRON HYDROXIDE OXIDE; (HYDRATED IRON OXIDE)
CAS:20344-49-4
Fraction by Wt: 1.0%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:AMMONIA (SARA 302/313) (CERCLA)
CAS:7664-41-7
RTECS #:BO0875000
Fraction by Wt: <0.1%
OSHA PEL:50 PPM
ACGIH TLV:25 PPM/35 STEL; 9495
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:1,2-PROPANEDIOL; (PROPYLENE GLYCOL)
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: 3.8%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, SOLVENT-REFINED
(SEVERE) HEAVY PARAFFINIC; (ALIPHATIC PETROLEUM DISTILLATE)
CAS:64741-88-4
RTECS #:PY8040501
Fraction by Wt: 0.4%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PALYGORSKITE; (MAGNESIUM ALUMINUM SILICATE)
CAS:12174-11-7
RTECS #:RT6400000
Fraction by Wt: 0.3%
OSHA PEL:15MG/M3
ACGIH TLV:10MG/M3
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (CRYSTALLINE SILICA)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <0.1%
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST;9495
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IN A CONFINED AREA VAPORS IN
HIGH CONCENTRATION ARE ANESTHETIC. IRRITANT TO UPPER RESPIRATORY
SYSTEM. LIGHTHEADEDNESS AND STAGGERED GAIT. CHRONIC: PROBLEMS WITH
RESPIRATORY SYSTEM MAY BE AGGRAV ATED BY EXPOSURE TO VAPORS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:CHRONIC PROBLEMS WITH RESPIRATORY
SYSTEM MAY BE AGGRAVATED TO EXPOSURE TO VAPORS.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMEDIATELY . INHAL: REMOVE FROM EXPOSURE -
RESTORE BREATHING - KEEP WARM AND QUIET. SKIN: WASH FROM SKIN WITH
SOAP AND WATER. EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. G
ET MEDICAL AID. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:199F,93C
Extinguishing Media:NON-COMBUSTIBLE - FOR DRY SOLIDS USE WATER, FOAM
CO*2, DRY CHEMICALS.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS EXPOSED TO EXTREME HEAT
MAY RUPTURE DUE TO PRESSURE BUILD-UP. CONTENTS MAY SPATTER IF
TEMPERATURE EXCEEDS 212F.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DOL STORAGE CATEGORY 3B.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . DEVICE APPROVED BY NIOSH.
Ventilation:LOCAL EXHAUST: PREFERABLE MECHANICAL (GENERAL): ACCEPTED.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:AVOID BREATHING VAPOR OR SPRAY MIST. AVOID
CONTACT WITH SKIN OR EYES.
Supplemental Safety and Health
EVAP RATE: SLOWER THAN ETHER (BUTYL ACETATE =1)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Density:HVR/AIR
Spec Gravity:1.36 (H*2O = 1)
Evaporation Rate & Reference:SUPDAT
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORED PIGMENTED LIQUID WITH SLIGHT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NO HAZADOUS REACTIONS ARE EXPECTED UNDER NORMAL USE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE AND CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS. DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS REGARDING POLLUTION.
| 1 | eyes_protection_mandatory |
=======================================================
NIIN: 01-147-9957
Product ID: TPA-150 PART A & B #80-6106-1035-6
Kit Part: Y
Cage: 0F0U5
=======================================================
Contractor Summary
=======================================================
Cage: 04963
Cage: 0F0U5
Country: UK
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: ADHESIVE
Unit of Issue: KT
UI Container Qty: 0
=======================================================
Ingredients
=======================================================
% Wt: 80-90
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
-----------------------------
Cas: 67762-90-7
% Wt: 5-10
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Cas: 1332-58-7
RTECS #: GF1670500
% Wt: 1-5
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 10 MG/M3
ACGIH TLV: 2 MG/M3
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: CORROSIVE. IRRITATING TO SKIN & TO RESPIRATORY SYSTEM.
Signs And Symptions Of Overexposure: SKIN:
REDNESS/ITCHING/DRYNESS/SCALY/CRACKING.
First Aid: EYES: IMMED FLUSH W/PLENTY WATER. GET IMMED MED AID. INHALATION: IF
SIGHS/SYMPTOMS OCCUR, GET FRESH AIR. IF SIGNS/SYMP CONTINUE CALL DR. SKIN:
IMMED FLUSH W/LOTS WATER >15 MIN IN CHEM SAFETY SHOWER, R EMOVING CONTAM
CLOTHES/SHOES. GET IMMEDMED AID. WASH CONTAM CLOTHES BEFORE REUSE. INGEST:
DON'T INDUCE VOMITING. GIVE 2 GLASSES WATER. CALL DR IMMED. NEVER GIVE
ANYTHING BY MOUTH IF UNCONSCIOUS.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: CALL 612-733-1110/612-733-6100 FOR 24 HOUR SPILL
ASSISTANCE. VENTILATE AREA. EXTINGUISH ALL IGNIT SOURCES. CONTAIN SPILL.
COVER W/ABSORBENT. COLLECT SPILLED MAT'L. CLEAN UP RESIDUE W/WATER. PLACE IN
C LOSED CONTAINER.
Waste Disposal Methods: INCINERATE UNCURRED WASTE IN INDUSTRIAL/COMMERCIAL
INCINERATOR. DISPOSE OF COMPLETELY CURRED OR POLYMERIZED MAT'L IN SANITARY
LANDFILL.
Handling And Storage Precautions: STORE IN COOL PLACE. KEEP CONTAINER CLOSED
WHEN NOT IN USE. KEEP IN A WELL-VENTILATED AREA.
Other Precautions: KEEP CONTAINER TIGHTLY CLOSED. KEEP AWAY FORM HEAT, SPARKS,
OPEN GLAME, OTHER IGNITION SOURCES.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: >200F,>93C
Extinguishing Media: WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: WEAR FULL PROTECT CLOTHES: HELMET, POS PRES/PRESSURE
DEMAND SCBA, BUNKER COAT/PANTS, BANDS AROUND ARMS/WAIST/LEGS, FACE-MASK.
PROTECT EXPOSED AREAS OF HEAD.
Unusual Fire/Explosion Hazard: NONE KNOWN
=======================================================
Control Measures
=======================================================
Respiratory Protection: AVOID BREATHING VAPORS. USE HALF-MASK ORGANIC VAPOR
RESPIRATOR OR FULL-FACE ORGANIC VAPOR RESPIRATOR.
Ventilation: LOCAL EXHAUST OR APPROPRIATE RESPIRATORY PROTECTION.
Other Protective Equipment: NA
Work Hygienic Practices: DON'T EAT/DRINK/SMOKE. WASH EXPOSED SKIN THOROUGHLY
W/SOAP & WATER.
Supplemental Safety and Health: AVOID EYE/SKIN CONTACT. AVOID PROLONGED
BREATHING OF VAPORS.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: NA
Spec Gravity: 1.26
Viscosity: 60000
Solubility in Water: NIL
Appearance and Odor: BLACK PASTE
Percent Volatiles by Volume: 0
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 111050
Product ID: TPA-150 PART A & B #80-6106-1035-6
Review Date: 05/16/1996
Multiple KIT Number: 0
Kit Part IND: Y
Review IND: Y
Unit Of Issue: KT
Container QTY: 0
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: TPA-150 PART A & B #80-6106-1035-6
Cage: 0F0U5
Company Name: PACEBROOK LTD
Street: 15 GOSDITCH ST
Zipcode: 00000
Country: UK
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: CORROSIVE. IRRITATING TO SKIN & TO RESPIRATORY
SYSTEM.
SKIN: REDNESS/ITCHING/DRYNESS/SCALY/CRACKING.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MILDEW REMOVER
CAGE:0PWJ2
CAGE:0PWJ2
============= Composition/Information on Ingredients =============
Ingred Name:HYPOCHLOROUS ACID, SODIUM SALT; (SODIUM HYPOCHLORITE)
(CERCLA)
CAS:7681-52-9
RTECS #:NH3486300
Fraction by Wt: 5-10%
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:POTASSIUM HYDROXIDE (CERCLA)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 3-8%
OSHA PEL:2 MG/M3, C
ACGIH TLV:2 MG/M3, C
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOLATILE ORGANIC COMPOUNDS: NOT APPLICABLE.
RTECS #:9999999VO
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IT IS IMPORTANT TO DETERMINE WHETHER
EXPOS IS TO CONCENTRATED/DILUTE PROD. INFO INCLUDED IN THIS
DOCUMENT IS INTENDED TO DEAL W/EXPOS TO CONCENTRATED PROD.
GENERALLY, EXPOS TO DILUTED PROD WILL RSLT I N SUBSTANTIALLY LESS
RISK OF INJURY THAN DESCRIBED HEREIN. ACUTE:EYE CONTACT: CAUSES
BURNS. SKIN: (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:CONTACT W/CONCENTRATE SOLUTION WILL
RESULT IN DRY SKIN. PROLONGED OR REPEATED CONTACT MAY CAUSE BURNS
OR INJURY. INHALATION:VAPORS OR MIST MAY CAUSE IRRITATION OF NASAL
& RESPIRATORY PASSAGES . INGESTION:CAN CAUSE GASTROINTESTINAL
IRRITATION, NAUSEA, VOMITING OR DIARRHEA. CHRONIC:NO DATA.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:IMMEDIATELY FLUSH W/PLENTY OF WATER FOR AT LEAST 15
MINUTES. CALL MD. SKIN:WASH AFFECTED AREA W/SOAP & WATER.
INHAL:REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT, GIVE OXYGEN &
CALL MD. INGEST:G IVE MODERATE AMOUNTS OF WATER. DO NOT INDUCE
VOMITING. CALL MD.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Extinguishing Media:WATER SPRAY, FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . EVACUATE NON-ESSENTIAL PEOPLE.
Unusual Fire/Explosion Hazard:USE WATER FOG/SPRAY TO COOL & LOWER THE
PRESSURE OF FIRE EXPOSED CONTAINERS, TO FLUSH VAPORS AWAY.
================== Accidental Release Measures ==================
Spill Release Procedures:WARNING:FLOOR SURF MAY BE SLIPPERY; USE CARE
WALKING, WORKING & STANDING. LG SPILLS:(>55 GALS) EVACUATE
NON-ESSNTL PERS. WEAR APPROP PROT CLTHG & RUBBER BOOTS. SHUT OFF
SOURCE OF LEAK IF SAFE TO DO SO . DIKE & CONTAIN SPILL W/INERT MATL
(E.G. (SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM STRONG ACID & REDUCING
AGENT.
Other Precautions:CAUTION:KEEP OUT OF REACH OF CHILDREN. DO NOT GET IN
EYES, ON SKIN OR ON CLOTHING. DO NOT TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR MISTS & SPRAYED MATERIAL USE NIOSH/MSHA
APPROVED RESPIRATOR.
Ventilation:IN CONFINED AREAS PROVIDE ADEQUATE LOCAL EXHAUST
VENTILATION.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PH:13 +/- 1. SPILL PROC:SAND, EARTH). TRANSFER LIQUID TO CONTAINERS FOR
RECOVERY OR DISPOSAL. SMALL SPILLS:MOP UP & RINSE AREA. EYE PROT:&
FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:DECOMPOSES
Melt/Freeze Pt:M.P/F.P Text:32F,0C
Vapor Pres:<17 @ 68F
Vapor Density:>1
Spec Gravity:1.07
pH:SUPDAT
Evaporation Rate & Reference:>1 (BUTYL ACETATE=1)
Solubility in Water:SOLUBLE (100%)
Appearance and Odor:YELLOW LIQUID; PUNGENT ODOR.
Percent Volatiles by Volume:90(WT)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
STRONG ACIDS, REDUCING AGENT.
Stability Condition to Avoid:HEAT, TEMPERATURE EXTREMES, LIGHT.
Hazardous Decomposition Products:CARBON OXIDES. HYDROGEN CHLORIDE,
CHLORINE &/OR OXYGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTES I/A/W FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:83-9-104254 FUSER OIL
CAGE:HO249
CAGE:HO249
CAGE:09177
============= Composition/Information on Ingredients =============
Ingred Name:POLYDIMETHYL SILOXANE
CAS:9016-00-6
RTECS #:TQ2690000
Fraction by Wt: 100%
===================== Hazards Identification =====================
Effects of Overexposure:MAY CAUSE TEMPORARY DISCOMFORT TO EYES
======================= First Aid Measures =======================
First Aid:EYE: FLUSH WITH WATER 15 MINUTES,GET MEDICAL ATTN.
===================== Fire Fighting Measures =====================
Flash Point:500F/260C (OC)
Extinguishing Media:CARBON DIOXIDE,FOAM
Fire Fighting Procedures:NONE (MFR)
Unusual Fire/Explosion Hazard:NONE (MFR)
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE AND ABSORB WITH INERT ABSORBENT MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:NORMAL STORING PROCEDURES
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN.
Ventilation:MECHANICAL/GENERAL
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>300F/148C
Vapor Pres:<5
Spec Gravity:1.0
Solubility in Water:NEGLIGIBLE
Percent Volatiles by Volume:<5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:SI0*2,CO*2,& TRACE OF INCOMPLETE
BURNED CARBON PRODUCTS
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TA-0670 938 SANDED GROUT
CAGE:IO191
CAGE:7P551
CAGE:IO191
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 50-70%
OSHA PEL:N/K
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:IRON (III) OXIDE
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 1-5%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3 FUME (FE)
Ingred Name:SILICATE, PORTLAND CEMENT
CAS:65997-15-1
RTECS #:VV8770000
Fraction by Wt: 30-50%
OSHA PEL:50 MPPCF
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: PORTLAND CEMENT CAN CAUSE
EYE IRRITATION BY ABSORBING WATER FROM EYES. SKIN: PORTLAND CEMENT
CAN CAUSE IRRITATION BY ABSORBING WATER FROM SKIN. INHALATION: DUST
MAY IRRITATE RESPIRATORY T RACT IN SENSITIVE INDIVIDUALS.
INGESTION: NOT AN ANTICIPATED ROUTE OF EXPOSURE. SMALL AMOUNTS ARE
NOT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE QUARTZ:IARC MONO, V
68, 1997:GROUP 1. NTP 7TH ANNUAL RPT ON CARCINS, 1994:ANTIC TO BE
CARCINOGEN.
Effects of Overexposure:HLTH HAZ:ANTICIPATED TO BE HARMFUL. CHRONIC:
LONG-TERM CRYSTALLINE SILICA EXPOSURE CAN CAUSE PERMANENT LUNG
DAMAGE AND REDUCED PULMONARY FUNCTION. OVEREXPOSURE TO IRON OXIDE
DUSTS MAY CAUSE SIDEROSIS.
Medical Cond Aggravated by Exposure:INHALATION OF DUST MAY AGGRAVATE
LUNG CONDITIONS SUCH AS ASTHMA, EMPHYSEMA OR CHRONIC BRONCHITIS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
OXYGEN/ARTIFICIAL RESPIRATION) . SKIN: FLUSH W/COPIOUS AMOUNTS OF
WATER. CALL MD . EYE: FLUSH WITH WATER FOR AT LEAST 15 MINUTES.
INGEST : IF PERSON CAN SWALLOW, GIVE 1 GLASS OF WATER OR MILK. DO
NOT INDUCE VOMITING. GET IMMEDIATE MEDICAL ATTENTION. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUSNESS PERSON.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE WATER SPRAY, FOAM, DRY CHEMICAL OR CARBON
DIOXIDE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:DUST CLOUDS IN AIR CAN BE IGNITED BY
ELECTRIC SPARKS, HOT SURFACES AND OPEN FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP OR VACUUM IMMEDIATELY; AVOID CREATING
DUSTY CONDITIONS. MATERIAL CAN ABSORB WATER AND BECOME SLIPPERY.
SHOVEL UP WET MATERIAL AND FLUSH AREA WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONSULT THE TECHNICAL DATA SHEET FOR
SPECIFIC STORAGE INSTRUCTIONS.
Other Precautions:AVOID BREATHING DUST. THIS PRODUCT CONTAINS
CHEMICAL(S) KNOWN TO STATE OF CALIFORNIA TO CAUSE CANCER OR
REPRODUCTIVE DAMAGE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED. USE NIOSH APPROVED
PARTICULATE RESPIRATOR IF CONDITIONS WARRANT.
Ventilation:IF PRODUCT IS ALLOWED TO BECOME AIRBORNE AS DUST, AN
EXHAUST FAN W/AN EXPLOSION-PROOF MOTOR IS RECOMMENDED.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:GOOD HOUSEKEEPING SHOULD BE PRACTICED TO AVOID
DISSEMINATION OF DUST. SOURCES OF IGNIT SHOULD BE ELIMINATED
(SUPDAT)
Supplemental Safety and Health
HYGIENE PRACT:FROM DUSTY AREAS.
================== Physical/Chemical Properties ==================
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:NOT KNOWN
Appearance and Odor:938 CHOCOLATE BROWN POWDER, NO ODOR.
Percent Volatiles by Volume:100 WT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NOT ESTABLISHED.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION CAN YIELD CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:TO BEST OF MFR'S KNOWLEDGE, PROD DOES NOT MEET
DEFINITION OF HAZ WASTE UNDER U.S. EPA HAZ WASTE REGS 40 CFR 261.
DISPOSE OF IN APPRVD LANDFILL. CONSULT FEDERAL, STATE, LOCAL OR
PROVINCIAL AUTHORITIES FOR MORE RESTRICTIVE REQUIREMENTS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CRONEX X-RAY MANUAL DEVELOPER,PART-B/MXD-B
CAGE:DO962
CAGE:18873
CAGE:DO962
============= Composition/Information on Ingredients =============
Ingred Name:ACETIC ACID (SARA III)
CAS:64-19-7
RTECS #:AF1225000
Fraction by Wt: 67.0%
OSHA PEL:10 PPM
ACGIH TLV:10 PPM/15 STEL; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WATER; CAS #7732-18-5
CAS:7732-18-5
RTECS #:ZC0110000
===================== Hazards Identification =====================
Effects of Overexposure:SKIN/EYES:CAUSES BURNS;INHAL:CAUSES SEV IRRIT
TO RESP SYS & DENTAL ERROSION;INGEST:CAUSES GI CORROSN
======================= First Aid Measures =======================
First Aid:SKIN:WASH W.SOAP & H*2O. EYES:FLUSH W. H*2O. INGESTED:DON'T
INDUCE VOMITING. INHALED:REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF
NEED. KEEP WARM & QUIET. REMOVE CONTAMINATED CLOTHING. NEVER GIVE
ANYTHING BY MOUTH TO UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER,WATER SPRAY/FOG,CHEM FOAM,DRY CHEM,CO*2
Fire Fighting Procedures:EVACUATE PERSONS TO SAFE AREA&KEEP UPWIND.WEAR
SCBA.COOL CON
Unusual Fire/Explosion Hazard:NONE NOTED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:USE APPROPRIATE PERSONA PROTECTIVE EQUIP
DURING CLEAN UP.DIKE SPILL.PREVENT LIQUID FROM ENTERING
SEWERS,WATER WAYS OR LOW AREAS.SOAK UP WITH SAWDUST,SAND,OIL DRY OR
OTHER ABSORBENT MATERIAL.SPILL MAYBE NEUTRALIZE W SODIUM
BICARBONATE BEFORE DISPOSL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL CONTACT. KEEP
CONTAINERS TIGHTLY CLOSED
Other Precautions:USE ONLY W/ADEQUATE VENTILATION.DO NOT MIX W/STRONG
BASES.DO NOT STORE OR CONSUME FOOD IN AREA WHERE THEY MAY BECOME
CONTAMNTD WITH THIS MATL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF NEEDED,USE CHEMICAL CARTRIDGE RESPIRATOR
W/ORGANIC VAP CARTRIDGE
Ventilation:NO SPECIAL REQUIREMENTS W ADEQUATE VENT.
Other Protective Equipment:FULL WORK CLOTHING TO PREVENT REPEATED OR
PROLONGED CONTACT.
Supplemental Safety and Health
KEY1:P01;MSDS FM DUPONT DATED:11/85; THIS REPRESENTS NEW FORMULATION OF
PART-B OF TWO PARTS PRODUCTS; SEE P/N IND "B" FOR OLD PART WHICH
HAS BEEN CANCELLED/CHANGED-PER DLSC-TIR;PH=1.3.
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:>212F/>100C
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR,LIGHT AMBER LIQUID WITH VINEGAR ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES & OXIDIZERS
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:EMITS CO,CO*2.
==================== Disposal Considerations ====================
Waste Disposal Methods:RECOVER NONUSABLE FREE LIQUID AND/OR
CONTAMINATED WATER,AND DISPOSE OF IN AN APPRVD BIOLOGICAL TREATMENT
SYSTEM OR AN APPRVD DEEPWELL.RMV NONUSABLE SOLID MATL &/OR
CONTAMNTD SOIL,FOR DISPOSAL IN AN AP PRVD LANDFILL.FED,STATE,LOCAL
REGS TAKEPRECEDENCE
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:GAGE BLOCK PRESERVATIVE, AEROSOL
Preparer's Name:R.R. ROGERS
CAGE:02637
CAGE:02637
============= Composition/Information on Ingredients =============
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROETHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 35%.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:350 PPM
ACGIH TLV:350 PPM/450STEL;9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:METHYLENE CHLORIDE(SARA III)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 40%
OSHA PEL:500 PPM/C,1000; Z2
ACGIH TLV:50 PPM, A2; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ALIPHATIC PETROLEUM DISTILLATE
CAS:64742-88-7
Fraction by Wt: 6%
OSHA PEL:ND
ACGIH TLV:100 PPM
Ingred Name:ALIPHATIC PETROLEUM DISTILLATE
CAS:64742-65-0
RTECS #:PY8038500
Fraction by Wt: 3%
OSHA PEL:5 MG/CUM AS MIST
ACGIH TLV:5 MG/CUM
Ingred Name:2-BUTOXYETHANOL
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 1%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
Ingred Name:HYDROCARBON PROPELLANT
CAS:68476-85-7
RTECS #:DJ2200000
Fraction by Wt: 15%
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHXIANT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:INHALATION: IRRI, DIZZINESS, NARCOTIC
EFFECT. EYES: IRRI. SKIN: DEFATTING, IRRI,REDNESS. & INGEST: IRRI.
BEWARE OF ASPIRATION FROM VOMITING. CHRONIC: REPEATED SKIN CONTACT
MAY PRODUCE A DRY, SCALY, & FISSURED DERMATITIS. INTENSE PROLONGED
EXPOSURE MAY LEAD TO REDUCED LIVER FUNCTION, CARDIAC ARRYTHMIAS
Medical Cond Aggravated by Exposure:PRE-EXISTING DISORDERS OF EYES,
SKIN, LIVER, CARDIOVASCULAR SYSTEM, RESPIRATORY SYSTEM, CENTRAL
NERVOUS SYSTEM
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SUPPORT BREATHING IF
NECESSARY. GET MED. ATTN. EYES: REMOVE CONTACT LENSES. FLUSH WITH
WATER FOR 15 MIN. LIFTING LIDS. SKIN: PROMPTLY WASH EXPOSED AREA
W/MILD SOAP & W ARM WATER. DON'T USE HARSH SOLVENTS. IN-GESTION:
KEEP PERSON WARM & QUIET. GET MED. ADVICE BEFORE TAKING FURTHER
ACTION.DANGER FROM LUNG ASPIR MUST BE WEIGHED AGAINST TOXICITY WHEN
CONSID EMPTY STOMAC
===================== Fire Fighting Measures =====================
Flash Point:-123 F -85.60 C
Lower Limits:9.5
Upper Limits:1.9
Extinguishing Media:FOAM, CARBON DIOXIDE, AND DRY CHEMICAL
Fire Fighting Procedures:WTR STREAM/SPRAY TO KEEP CONTAINER COOL TO
LIMIT VAPOR EVOLUTION. PROVIDE SHIELDAGAINST HEAT INDUCE PRESSURE
RISE RUPTURE OF CONTAINERS. ENTER FIRE ARE W/SCBA
Unusual Fire/Explosion Hazard:CONT MAY VENT, RUPTURE, BURST
EXPLOSIVELY. IF HEATED TO DECOMP TEMP, TOXIC FUMESOF CHLORINE
COMPOUNDS MAY BE FORMED
================== Accidental Release Measures ==================
Spill Release Procedures:LARGE: EVACUATE AREA. USE SCBA RESPIRATOR.
EXTINGUISH IGNIT SOURCE. CONTAIN SPILL-PREVENT ENTRY INTOWATER
SUPPLY. CONTAINERIZE. VENT TO REMOVE RESIDUEVAPOR. SML: SEE ABOVE.
MOP/SOAK UP W/INERT ABSORBE NT. REMOVE MOP/ABSORBENT OUT OF DOORS
IMMEDIATELY
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT PUNCTURE OR INCINERATE AEROSOL
CANS. DON'T STICK PINS, ETC INTO OPENING ON TOP OF CAN. STORE IN
COOL DRY PLACE AWAY FROM LIKELY FIRE SOURCES
Other Precautions:USE WITH ADEQUATE VENTILATION. DON'T BREATH VAPORS.
DON'T SMOKE WHILE USING. DON'T USE NEAR FLAMES OR VERY HOT
SURFACES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV EXCEEDED - ANY AIR SUPPLIED RESPIRATOR
Ventilation:LOCAL, TO CONTROL VAPORS TO STANDARD. MECHANICAL, SAME.
SPECIAL, SEE ABOVE
Other Protective Equipment:DEPENDING UPON EXPECTED EXPOSURE - SOLVENT
RESISTANT CLOTHING
Work Hygienic Practices:AVOID BREATHING VAPORS. PROLONGED CONTACT WITH
SKIN/EYES. WASH WITH MILD SOAP/WARM WATER AFTER EACH USE. DON'T
SMOKE
Supplemental Safety and Health
DON'T USE HARSH SOLVENTS. LAUNDER SOAKED CLOTHES BEFORE REUSE.
NOTE TO PHYSICIAN: DANGER FROM LUNG ASPIRATION MUST BE
WEIGHTED AGAINST TOXICITYWHEN CONSIDERING EMPTYING THE STOMACH. E
XPOSURE MAY INCREASE MYOCARDIAL IRRITABILITY
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NA
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:NA
Vapor Density:> 1. AIR
Spec Gravity:1.06
pH:NA
Evaporation Rate & Reference:< 1. BUTYL ACETATE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WET MIST SPRAY WITH CHLORINATED SOLVENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS OR CAUSTICS
Stability Condition to Avoid:DROPPING AS CANS MAY BURST. OPEN FLAMES,
HOT SURFACES
Hazardous Decomposition Products:CARBON MONOXIDE, TOXIC CHLORINE
COMPOUNDS
==================== Disposal Considerations ====================
Waste Disposal Methods:UNDER RCRA, IT'S RESP OF USER TO DETERMINE AT
TIMEOF DISPOSAL, WHETHER PRODUCT MEETS RCRA CRITERIA FOR HAZARDOUS
WASTE. BECAUSE PRODUCT TRANSFORM, MIXTURE, PROCESSES, ETC. MAY
RENDER THE RESULT MATER IAL NONHAZARDOUS OR HAZARDOUS
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BRAYCO 815Z
Resp. Party Other MSDS Num.:27090A
CAGE:2R128
DIV
CAGE:2R128
Contract Num:SP0450-99-M-B269
CAGE:0PGK2
============= Composition/Information on Ingredients =============
Ingred Name:CONTAINS NO INGREDIENTS NOW KNOWN TO BE HAZARDOUS BY OSHA
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: NONE SPECIFIED BY
MANUFACTURER. EYE: MAY CAUSE EYE IRRITATION. SKIN CONTACT:
CONCENTRATE MAY CAUSE SKIN IRRITATION. SKIN ABSORPTION: NO ACUTE
EFFECTS EXPECTED. INGESTION: THIS PRODUCT M AY CAUSE
GASTROINTESTINAL DISTRESS. INHALATION: INHALATION OF DECOMPOSITION
PRODUCTS OR OF SMOKE FROM CONTAMINATED TOBACCO PRODUCTS MAY CAUSE
RESPIRATORY IRRITATION AND INDUCE POLYMER FUME FEVER. CHRO NIC: A
REVIEW OF THE LITERATURE DOES NOT SHOW OBVIOUS LONG TERM HAZARD.
Explanation of Carcinogenicity:NO COMPONENT PRESENT IN THIS PRODUCT AT
>0.1% IS PRESENTLY LISTED AS A CARCINOGEN BY THE IARC, NTP OR OSHA.
Effects of Overexposure:EYES & SKIN-IRRITATION. INGESTION-NAUSEA,
VOMITING, DIARRHEA, ABDOMINAL PAIN. INHALATION-RESPIRATORY
IRRITATION, POLYMER FUME FEVER.
Medical Cond Aggravated by Exposure:NO MEDICAL CONDITIONS ARE KNOWN TO
BE AGGRAVATED BY EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYES-FLUSH WITH WATER. GET MEDICAL ATTENTION IF IRRITATION
OCCURS. SKIN-WASH THOROUGHLY WITH SOAP & WATER. OBTAIN IMMEDIATE
MEDICAL ATTENTION IF GREASE INJECTED UNDER SKIN. INGESTION-DO NOT
INDUCE VO MITING. IMMEDIATELY GIVE 2 GLASSES OF CHARCOAL SLURRY OR
WATER. DO NOT ATTEMPT TO GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON. CONTACT A PHYSICIAN. INHALATION-REMOVE FROM EXPOSURE AREA
TO FRESH AI R IMMEDIATELY. ADMINISTER OXYGEN IF NECESSARY. POLYMER
FUME FEVER SYMPTOMS SHOULD SUBSIDE IN 24 HOURS.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:N/D
Extinguishing Media:NOT A FIRE HAZARD.
Fire Fighting Procedures:WATER OR FOAM MAY CAUSE FROTHING.USE WATER TO
KEEP FIRE EXPOSED CONTAINER COOL.WATER SPRAY MAY BE USED TO FLUSH
SPILLS AWAY FROM EXPOSURE.FOR FIRES IN ENCLOSED AREAS,FIREFIGHTERS
MUST USE SELF-CONTAIN ED BREATHING APPARATUS.PREVENT RUNOFF FROM
FIRE CONTROL OR DILUTION FROM ENTERING STREAMS OR DRINKING WATER
SUPPLY.
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR APPROPRIATE PROTECTIVE CLOTHING. STOP
LEAK AT SOURCE IF POSSIBLE. DIKE, CONTAIN SPILL & RECOVER FREE
LIQUID. PREVENT ENTRY INTO WATERWAYS. SOAK UP WITH INERT MATERIAL.
STORE & DISPOSE OF PROPERLY . FLUSH AREA WITH WATER. WHERE FEASIBLE
& APPROPRIATE, REMOVE CONTAMINATED SOIL. SMALL SPILL:
NEUTRALIZE/SOAK UP WITH INERT ABSORBENT. STORE IN A CLOSED
CONTAINER & DISPOSE PROPERLY.
Neutralizing Agent:NONE SPECIFIED BY MNUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:MAINTAIN AMBIENT TEMPERATURES. AVOID
PROLONGED/REPEATED BREATHING OF VAPORS, MISTS, FUMES. KEEP
CONTAINERS TIGHTLY CLOSED. DO NOT STORE NEAR HEAT, FLAME, STRONG
OXIDANTS. MAINTAIN ADEQUATE VENTILATION .
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:PROVIDE NIOSH-APPROVED RESPIRATORY
PROTECTION.NOT NORMALLY REQUIRED;PROVIDE EXHAUST IF TEMPERATURE IS
EXPECTED TO EXCEED 300C.
Ventilation:ENGINEERING BE USED TO REDUCE ENVIRONMENTAL CONCENTRATIONS
TO THE THRESHOLD LIMIT VALUE.PROVIDE EXHAUST IF TEMPERATURE EXCEEDS
300C.
Other Protective Equipment:IMPERVIOUS PROTECTIVE CLOTHING AND CHEMICAL
RESISTANT SAFETY SHOES.EMERGENCY SHOWER AND EYEWASH FACILITY SHOULD
BE PROVIDED IN ALL AREAS IN WHICH THIS PRODUCT IS HANDLED.
Work Hygienic Practices:WASH CONTAMINATED CLOTHING WITH SOAP AND WATER
AND DRY BEFORE REUSE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:>260.C, 500.F
Decomp Temp:>200.C, 392.F
Vapor Pres:<10 -7 @20C
Vapor Density:N/D
Spec Gravity:1.8000+/-
Evaporation Rate & Reference:N/D(NBUAC=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR,COLORLESS FLUID,MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACTIVE METALS,METAL OXIDES AT TEMPERATURES >280C.LEWIS ACID
CATALYSTS,STRONG OR NON-AQUEOUS ALKALI
Stability Condition to Avoid:NONE KNOWN
Hazardous Decomposition Products:HIGH TEMPERATURES (>200C) YIELDS
HYDROGEN FLUORIDE,CARBONYL FLUORIDE,AND OTHER ACID FLUORIDES
=================== Toxicological Information===================
Toxicological Information:EYE: MAY CAUSE EYE IRRITATION. SKIN CONTACT:
CONCENTRATE MAY CAUSE SKIN IRRITATION. SKIN ABSORPTION: NO ACUTE
EFFECTS EXPECTED. INGESTION: THIS PRODUCT MAY CAUSE
GASTROINTESTINAL DISTRESS. INHALATION: INHALATION OF DECOMPOSITION
PRODUCTS OR OF SMOKE FROM CONTAMINATED TOBACCO PRODUCTS MAY CAUSE
RESPIRATORY IRRITATION AND INDUCE POLYMER FUME FEVER. CHRONIC: A
REVIEW OF LITERATURE DOES NOT SHOW OBVIO US LONG TERM HAZARD.
===================== Ecological Information =====================
Ecological:NO SPECIFIC ECOLOGICAL DATA ARE AVAILABLE FOR THIS PRODUCT.
==================== Disposal Considerations ====================
Waste Disposal Methods:PRODUCT, AS PURCHASED, DOES NOT FALL UNDER
CURRENT US EPA RCRA DEFINITIONS OF HAZARDOUS WASTE. UNDER RCRA IT
IS THE GENERATOR'S RESPONSIBILITY TO DETERMINE THE STATUS OF THE
WASTE AT THE TIME OF ITS D ISPOSAL. PACKAGE, TRANSPORT & DISPOSE OF
IAW LOCAL, STATE & FEDERAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:US DOT PROPER SHIPPING NAME: NOT REGULATED.
===================== Regulatory Information =====================
SARA Title III Information:SECTION 302 EHS: NO LISTED INGREDIENTS ARE
PRESENT IN THE 302 LIST. SECTION 311/312: IMMEDIATE-YES;
DELAYED-NO; FIRE-NO; REACTIVITY-NO; SUDDEN RELEASE OF PRESSURE-NO.
SECTION 313: THERE ARE NO 313 CHE MICALS PRESENT ABOVE THRESHOLD
VALUES.
Federal Regulatory Information:HAZARDOUS PER OSHA 29 CFR 1910.1200:
YES. THIS PRODUCT IS A MIXTURE AND IS NOT LISTED IN THE TSCA
INVENTORY. THE INDIVIDUAL INGREDIENTS IN THE PRODUCT ARE LISTED IN
THE TSCA INVENTORY.
State Regulatory Information:NONE SPECIFIED BY MANUFACTURER.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SPRED ULTRA EXTERIOR GLOSS LATEX HOUSE AND
CAGE:72818
CAGE:72818
============= Composition/Information on Ingredients =============
Ingred Name:1,2-PROPANEDIOL; (PROPYLENE GLYCOL). LEL:2.6. VP:0.04 @ 68F
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: 5-10%
Ingred Name:C.I. PIGMENT YELLOW 42; (YELLOW IRON OXIDE)
CAS:51274-00-1
Fraction by Wt: 1-5%
OSHA PEL:10 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:PROPANOIC ACID, 2-METHYL-, MONOESTER WITH
2,2,4-TRIMETHYL-1,3-PENTANEDIOL; (TEXANOL). LEL:0.6%. VP:1.0 @ 188F
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: 1-5%
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (QUARTZ)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <1.0%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:ACRYLIC COPOLYMER. VP:17 @ 0F
Fraction by Wt: 20-30%
Ingred Name:WATER. VP:17.5 @ 68F
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 50-60%
Ingred Name:C.I. PIGMENT GREEN 7; (PHTHALOCYANINE GREEN)
CAS:1328-53-6
RTECS #:GE4300000
Fraction by Wt: 1-5%
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL:IRRIT OF RESP TRACT. SKIN:IRRIT.
PRLNGD/RPTD CONT CAN CAUSE DERM. MAY BE ABSORBED THROUGH SKIN.
EYES:IRRIT. INGEST:MAY CAUSE VOMIT, DIARR, CNS DEPRESS, KIDNEY DMG.
PRODS IN THIS SERIES CONTAIN C RYSTALLINE SILICA, WHICH IS
CONSIDERED A HAZ BY INHAL. CRYSTALLINE SILICA IS ALSO A KNOWN CAUSE
OF (EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE - QUARTZ:GROUP 2A,
IARC MONOGRAPHS, VOL 7, P.341, 1987; ANTICIPATED TO BE CARCINOGEN,
NTP (SUP DATA)
Effects of Overexposure:HLTH HAZ:SILICOSIS, A NONCANCEROUS LUNG
DISEASE. PROD IN THIS SERIES CONTAIN ETHYLENE GLYCOL WHEN TINTED
W/DRAMATONE. ETHYLENE GLYCOL CAN CAUSE SEV KIDNEY DMG WHEN INGEST
AND HAS BEEN SHOWN TO CAUSE B IRTH DEFECTS IN LAB ANIMALS.
Medical Cond Aggravated by Exposure:INGREDIENTS CONTAINED IN THESE
PRODUCTS HAVE BEEN REPORTED TO AGGRAVATE PREEXISTING EYE, SKIN,
RESPIRATORY, LUNG AND KIDNEY DISORDERS.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
GET EMERG MED ATTN. HAVE TRAINED PERSON GIVE OXYGEN IF NEC. GET MD
HELP FOR ANY BRTHG DFCLTY. SKIN:WASH OFF QUICKLY W/PLENTY OF WATER,
THE N SOAP & WATER. REMOVE CONTAM CLTHG. WASH CONTAM CLTHG BEFORE
REUSE. EYE:FLUSH IMMED W/LRG AMTS OF WATER, ESP UNDER LIDS, FOR AT
LEAST 15 MIN. IF IRRIT/OTHER EFTS PERSIST, OBTAIN MD ATTN. (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:SEE ING 1&3
Extinguishing Media:DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . WATER MAY BE USED TO COOL AND PROTECT
EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY BURST IF EXPOSED TO
EXTREME HEAT OR FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:COMPLY WITH ALL APPLICABLE HEALTH AND
ENVIRONMENTAL REGULATIONS. VENTILATE AREA. SPILL MAY BE COLLECTED
WITH ABSORBENT MATERIALS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 100F. KEEP FROM FREEZING.
USE ONLY WITH ADEQUATE VENTILATION. DO NOT TAKE INTERNALLY. KEEP
OUT OF REACH OF CHILDREN.
Other Precautions:KEEP CONTS TIGHTLY CLSD & UPRIGHT WHEN NOT IN USE.
AVOID CONDITIONS WHICH RESULT IN FORMULATION OF INHALABLE PARTICLES
SUCH AS SPRAYING/ABRADING (SANDING) PAINTED SURF. IF SUCH
CONDITIONS CANNOT BE AV OIDED, USE APPROP NIOSH/MSHA (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW
APPLICABLE STANDARDS. WHERE RESPIRATORY PROTECTION IS REQUIRED, USE
ONLY NIOSH/MSHA APPROVED RESPIRATORS IN ACCORDANCE WITH OSHA
STANDARD 29 CFR 1910.134.
Ventilation:PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT
BUILD-UP OF VAPORS.
Other Protective Equipment:EYE WASH, SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING,
ESPECIALLY BEFORE EATING OR SMOKING.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:TRIM PAINT, 6612. FIRST AID PROC:INGEST:OBTAIN
MEDICAL TREATMENT IMMEDIATELY. OTHER PREC:APPROVED RESPIRATORY
PROTECTION AS DIRECTED. AVOID CONTACT WITH SKIN AND EYES, AND BRE
ATHING OF VAPORS. EXPLANATION OF CARCINOGENICITY: SIXTH ANNUAL
REPORT ON CARCINOGENS, 1991 .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:SEE INGS
Spec Gravity:1.08
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:69.9
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ALUMINUM, ZINC, METALS, ACIDS, ALCOHOLS, MAGNESIUM, SODIUM,
POTASSIUM.
Stability Condition to Avoid:ELEVATED TEMPERATURES, CONTACT WITH
OXIDIZING AGENTS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE LOCAL,
STATE AND FEDERAL REGULATIONS. DISCHARGE TO NATURAL WATERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FA7840/2
CAGE:81341
CAGE:81341
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR.AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UNC ONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:POLYSHEEN MIDTONE, 055-0005
CAGE:42590
CAGE:42590
============= Composition/Information on Ingredients =============
Ingred Name:ALIPHATIC HYDROCARBON. VP: 2@68F
CAS:64742-88-7
Fraction by Wt: 25%
OSHA PEL:500 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:MAGNESIUM SILICATE HYDRATE
CAS:1343-90-4
RTECS #:OM4360000
Fraction by Wt: <5%
Other REC Limits:10 MG/M3 (MFR)
OSHA PEL:N/K
ACGIH TLV:20MPPCF
Ingred Name:VOLATILE ORGANIC COMPOUNDS: 2.96 LB/GL (355 G/L)
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: CAN CAUSE SEV IRRIT, RED,
TEAR, & BLURRED VISION. SKIN: CAN CAUSE MOD IRRIT, DEFAT, & DERM.
INHAL: CAN CAUSE NASAL & RESP IRRIT. ASPIR INTO LUNGS CAN CAUSE
CHEM PNEUM WHICH CAN BE FATAL. CHRONIC: PRLNGD/RPTD EXPOS ABOVE
TLV MAY RSLT IN PERM BRAIN & NERV SYS DAM. CHRONIC OVEREXP TO TIO*2
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: DUST MAY CAUSE SLIGHT LUNG FIBROSIS.
INHAL:EXCESS INHAL OF VAPS CAN CAUSE NASAL & RESP IRRIT, WEAK,
DIZZ, FATG, NAUS, HDCH & POSS UNCON & EVEN ASPHY. SKIN: PRLNGD/RPTD
CONT CAN CAUSE MOD IRR IT, DEFAT, DERM. EYE: CAN CAUSE SEV IRRIT,
RED, TEAR & BLURRED VISION. SKIN ABSORP: ORG SOLV ARE EASILY (SUPP
DATA)
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMED WITH LG AMTS OF WATER FOR AT LST 15 MIN.
TAKE TO A PHYS FOR MED TRTMT. SKIN: WASH AFFECTED AREAS W/SOAP &
WATER. REMOVE CONTAMD CLTHG. CONSULT A PHYS IF IRRIT PERSISTS.
INHAL: REMOVE TO FRESH AIR. RESTORE BRTHG. TREAT SYMPTOMATICALLY.
CONSULT A PHYS. INGEST: DRINK 1-2 GLASSES OF WATER TO DILUTE. DO
NOT INDUCE VOMIT. CONSULT A PHYS/POIS CTL CTR IMMED. TREAT
SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:109F,43C
Lower Limits:1%
Upper Limits:6%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . DURING EMER CNDTNS OVEREXP TO DECOMP PROD MAY CAUSE
IMMED/DELAYED HLTH HAZARDS.
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & MAY TRAVEL ALONG
GROUND & BE IGNITED BY HEAT, OPEN FLAME/OTHER IGNIT SOURCES. KEEP
CONTRS TIGHTLY CLSD. ISOLATE FROM HEAT, SPARKS,(SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. DIKE, CONTAIN,
OR ABSORB WITH INERT MATERIALS (SAND, VERMICULITE, ETC.). TRANSFER
TO CONTAINERS FOR RECOVERY OR DISPOSAL. PREVENT RUNOFF INTO SEWERS,
STREAMS, OR OTHER BODIES OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE OR USE NEAR SOURCES OF
HIGH TEMPERATURES, NEAR FIRE/OPEN FLAME, OR OTHER IGNITION SOURCES.
Other Precautions:DO NOT TAKE INTERNALLY. AVOID PROLONGED OR REPEATED
EXPOSURE TO LEVELS ABOVE TLV.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV IS EXCEEDED USE NIOSH/MSHA APPROVED
ORGANIC VAPOR AND MIST, NIOSH/MSHA APPROVED SUPPLIED AIR/SCBA.
Ventilation:USE ADEQUATE MECHANICAL (GENERAL &/OR LOCAL) VENTILATION TO
MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment:WEAR IMPERVIOUS CLOTHING. EYEWASH STATIONS.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING RESTROOMS.
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
EXPLO HAZ: ELEC EQUIP, & OPEN FLAMES. CLSD CONTRS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. EFTS OF OVEREXP: ABSORBED, DRYING OF SKIN,
RED/DERM ARE SIGNS OF RPTD/OVEREXP TO THEIR DEFAT ACTION. INGEST:
CAN CAUSE GI IRRIT, NAUS, VOMIT & DIARR. EYE PROT: OSHA PERMITTED
SAFETY GLASSES.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:310F,154C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:1.3(H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NONE
Appearance and Odor:TYPICAL FOR SOLVENT BASED COATING
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:DO NOT EXPOSE TO HIGH TEMPERATURES OR OPEN
IGNITION SOURCES.
Hazardous Decomposition Products:MAY FORM TOXIC MATERIALS, CARBON
DIOXIDE, CARBON MONOXIDE, VARIOUS HYDROCARBONS, ETC ON THERMAL
DECOMPOSITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W ALL LOCAL, STATE, OR FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BARRIER J
CAGE:03089
CAGE:03089
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 3-5%
OSHA PEL:200 PPM
ACGIH TLV:50 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE (SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 32-36%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM;150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BENZENE, ETHYL-; (ETHYL BENZENE) (SARA III)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 3-5%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM;125 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:POLYSILICONE RESIN
Fraction by Wt: 55-60%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:OPTICAL BRIGHTENER
Fraction by Wt: <0.1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER; (PROPYLENE
GLYCOL METHYLETHER ACETATE)
CAS:108-65-6
RTECS #:AI8925000
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATION OF NOSE, THROAT,
EYES, LUNGS & SKIN. INHALATION CAN CAUSE DIZZINESS, WEAKNESS,
FATIGUE, NAUSEA, HEADACHE, POSSIBLE NARCOSIS & ASPHYXIATION. MAY BE
ACCOMPANIED BY COUGHING, CHOKING OR ASTHMA LIKE BREATHING MAY BE
DELAYED REACTION. VAPOR SPRAY MIST OR LIQUID CAUSES SKIN & EYE
DISCOMFORT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:DUE TO DEFATTING ACTION.
CHRONIC:CARDIAC ABNORMS, ORGAN DMG CAN OCCUR. INTENTIONAL MISUSE BY
CONCENTRATING & INHALING CAN BE FATAL. NOTE:TOLUENE APPEARS ON NAVY
LIST OF OCCUP CHEM REPRO HAZS. SEEK CONSULTATION FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG & EXPOS
INFO .
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE SATURATED CLTHG. WASH SKIN W/GREEN TINCTURE OF
SOAP. EYES:FLUSH FOR AT LEAST 15 MINUTES W/WATER. INHAL:REMOVE
PATIENT TO FRESH AIR. CALL MD. PROVIDE OXYGEN IF BRTHG IS DFCLT.
INGEST:DO NOT INDUCE VOMIT. IF VOMIT OCCURS KEEP HEAD BELOW HIPS
TO AVOID ASPIR INTO LUNGS. NOTE TO MD:INGEST:IF CNDTNS SUCH AS LOSS
OF GAG REFLEX, CONVLS/UNCON OCCUR BEFORE EMESIS, GASTRIC LAVAGE
USING (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:45.0F,7.2C
Lower Limits:1%
Upper Limits:7%
Extinguishing Media:DRY CHEMICAL FOAM, CARBON DIOXIDE; WATER MAY BE
INEFFECTIVE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . FIGHT AS FLAMMABLE LIQUID FIRE. KEEP AWAY FROM HEAT,
SPARKS & OPEN FLAME.
Unusual Fire/Explosion Hazard:VAPOR IS FLAMMABLE & HEAVIER THAN AIR &
MAY TRAVEL TO SOURCE OF IGNITION & FLASHBACK. USE WATER TO KEEP
FIRE EXPOSED CONTAINERS COOL TO REDUCE PRESSURE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION. PROVIDE
VENTILATION OR NIOSH/MSHA APPROVED RESPIRATORY PROTECTION. LARGE
SPILLS MAY BE REMOVED W/NON-SPARKING TOOLS, SMALL SPILLS
W/ABSORBENT MATERIALS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID OPEN SPARKS & FLAMES.
Other Precautions:EMPTY CONTAINERS MAY RETAIN HAZARDOUS PROPERTIES. DO
NOT CUT, PUNCTURE OR WELD NEAR THE CONTAINER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATORS FOR ATMOSPHERES
CONTAINING ORGANIC MISTS OR INDEPENDENT AIR SUPPLY.
Ventilation:LOCAL EXHST:YES. MECHANICAL (GENERAL):EXPLOSION PROOF.
SPECIAL:DESIGNED & MAINTAINED TO PROVIDE VOL & PATTERNED (SUPDAT)
Other Protective Equipment:EMERG EYE WASH AND DELUGE SHOWER WHICH MEETS
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC:CUFFED ENDOTRACHEAL TUBE SHOULD BE CONSIDERED. VENT:TO
PREVENT VAPOR CONCENTRATION IN EXCESS OF TLV.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:280F,138C
Vapor Pres:19.4
Vapor Density:3.6
Spec Gravity:0.93 (H*2O=1)
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LOW VISCOSITY STRAW COLORED LIQUID W/AROMATIC ODOR.
Percent Volatiles by Volume:41-49
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:OPEN SPARKS & FLAMES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN & ACROLEIN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL REQUIRES COMPLIANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:WHITE TRAFFIC & ZONE MARKING PAINT, 11-3
CAGE:47695
CAGE:47695
============= Composition/Information on Ingredients =============
Ingred Name:CALCIUM CARBONATE; (MARBLE),(LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 40-45%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:NAPHTHA, LIGHT ALIPHATIC (PETROLEUM) (THIS MATERIAL
CONTAINS UP TO 5 VOL.% BENZENE AND 20 VOL.% N-HEXANE)
CAS:64742-89-8
Fraction by Wt: 20-25%
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 2-5%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:FILM FORMERS, RESINS, AND ADDITIVES
Fraction by Wt: 15-20%
Ingred Name:EFTS OF OVEREXP:OF CANCER FROM EXPOS. POTNTL FOR INHAL OF
TITANIUM DIOXIDE DUSTS FROM COATINGS IS VERY LIMITED. (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:SINCE OVEREXPS NOT EXPECTED, THERE IS NO SIGNIFICANT
HAZ FOR MAN. EYE WATERING, NAUS, DIZZ, & LOSS OF COORD(ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:ARE INDICATIONS THAT SOLV LEVELS ARE TOO HIGH.
REDNESS, ITCHING, BURNING SENSATION & VISUAL DISTURBANCES (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:MAY INDICATE EXCESSIVE EYE CONTACT. DRYNESS, ITCHING,
CRACKING, BURNING, REDNESS, AND SWELLING ARE CNDTNS (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:ASSOCIATED W/EXCESSIVE SKIN CONTACT. NOTE:TOLUENE
(CAS# 108-88-3) APPEARS ON THE NAVY LISTING OF OCCUP (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:REPROD HAZARDS. SEEK CONSULTATION FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:AND SAFE HANDLING AND EXPOSURE RECOMMENDATIONS .
RTECS #:9999999ZZ
Ingred Name:RESP PROT:CAREFULLY TO DETERMINE THE TYPE OF AIRBORNE
CONTAMINANTS AGAINST WHICH THE RESPIRATOR IS EFFECTIVE (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:AND HOW IT IS TO BE PROPERLY FITTED.
RTECS #:9999999ZZ
Ingred Name:VENT:EXPOS LIMITS/LEL BELOW STATED LIMIT, & TO REMOVE
DECOMP PRODS DURING WELDING OR FLAME CUTTING ON SURFACES (ING 17)
RTECS #:9999999ZZ
Ingred Name:TITANIUM OXIDE;(TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 5-10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:ING 16:COATED WITH THIS PRODUCT.
RTECS #:9999999ZZ
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 10-15%
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:0.2 FIBERS/CC
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGEST:HARMFUL OR FATAL. EYE:CAUSES
IRRITATION. SKIN:MAY CAUSE MODERATE IRRITATION. INHAL:VAPOR & SPRAY
MIST MAY BE HARMFUL IF INHALED. VAPOR IRRITATES EYES, NOSE &
THROAT. REPEATED EXPOSURE TO HIGH V APOR CONCENTRATIONS MAY CAUSE
IRRITATION OF RESP SYS & PERM BRAIN & NERV SYS DMG. INTENTIONAL
MISUSE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:BY DELIBERATELY CONC & INHALING
CONTENTS MAY BE HARMFUL/FATAL. CHRONIC:AVOID LONG TERM & RPTD
CNTCT. PROD CNTNS TITANIUM DIOXIDE. ANIMALS INHALING MASSIVE QTYS
OF TITANIUM DIOXIDE DUST IN A L ONG-TERM STUDY DEVELOPED LUNG
TUMORS. STUDIES W/HUMANS INVOLVED IN MFR OF PIGMENT INDICATE NO
INCR RISK (ING 7)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:DO NOT INDUCE VOMITING. EYE:FLUSH IMMEDIATELY WITH
PLENTY OF WATER FOR AT LEAST 15 MINUTES. SKIN:FLUSH IMMED W/PLENTY
OF WATER, FOLLOWED BY WATERLESS HAND CLEANER & SOAP & WATER IF MATL
APPEARS TO ADHERE TO SKIN. INHAL:MOVE TO FRESHAIR. APPLY ARTF RESP
& OTHER SUPPORTIVE MEASURES AS REQ. IF INGESTION, ANY TYPE OF
OVEREXP OR SYMPS OF OVEREXP OCCUR DURING OR FOLLOWING USE OF PROD,
(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:40.0F,4.4C
Lower Limits:1.3%
Extinguishing Media:NFPA CLASS B EXTINGUISHERS (CO*2, DRY CHEMICAL, OR
UNIVERSAL TYPE AQUEOUS FILM FORMING FOAM) DESIGNED TO EXTING
(SUPDAT)
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER SPRAY MAY BE INEFTIVE BUT MAY BE USED TO COOL CLSD CNTNRS
TO PVNT PRESS BUILDUP & POSS (SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPARKS & OPEN FLAMES. CLSD CNTNRS MAY EXPLODE
WHEN EXPOSED TO EXTREME HEAT. DO NOT APPLY ON (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:PROVIDE MAXIMUM VENTILATION. ONLY PERS
IN AREA. REMOVE ALL IGNITION SOURCES. TAKE UP SPILLED MATERIAL
W/SAWDUST, VERMICULITE OR OTHE R ABSORB MATL & PLACE INTO CNTNR FOR
DISP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. STORE LARGE
QUANTITIES IN BUILDINGS DESIGED AND PROTECTED FOR STORAGE OF NFPA
CLASS IB FLAMMABLE LIQUIDS.
Other Precautions:IF MATL IS PART OF MULTIPLE COMPONENT COATING SYS,
READ MSDS FOR OTHER COMPONENT(S) BEFORE BLENDING AS RSLTG MIXTURE
MAY HAVE HAZARDS OF ALL ITS PARTS. CNTNRS SHOULD BE GROUNDED WHEN
POURING. AVOID FR EE FALL OF LIQ IN EXCESS OF FEW INCHES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:OVEREXP TO VAPS MAY BE PREVENTED BY ENSURING
VENT CNTRLS, VAP EXHST OR FRESH AIR ENTRY. NIOSH/MSHA APPROVD
(TC-23C-) AIR PURIFYING OR AIR SUPPLIED (TC-19C-) RESPS MAY ALSO
REDUCE EXPOS. READ RESP MFRS INSTRUCTIONS & LITERATURE (ING 14)
Ventilation:PROVIDE GEN DILUTION OR LOC EXHST VENT IN VOLUME & PATTERN
TO KEEP CONC OF INGREDS LISTED BELOW LOWEST SUGGESTED(ING 16)
Other Protective Equipment:IMPERMEABLE APRON.
Work Hygienic Practices:CLEAN OR DISCARD CONTAMINATED CLOTHING OR
SHOES.
Supplemental Safety and Health
EXTING MEDIA:NFPA CLASS IB FLAMM LIQ FIRES. EXPLO HAZ:HOT SURFS. TOX
GASES MAY FORM WHEN PROD IS CNTCTD BY FLAME/HOT SURFS. FIRE FIGHT
PROC:AUTOIGNIT OR EXPLO WHEN EXPOSED TO EXTREME HEAT/IF WATER IS
USED, FOG NOZZ ARE PREF. FIRST AID PROC:CALL POIS CTL CTR, EMERG
ROOM OR MD IMMED; HAVE MSDS INFORMATION AVAILABLE.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:>199F,>93C
Vapor Pres:20.2
Vapor Density:HVR/AIR
Spec Gravity:1.45
Evaporation Rate & Reference:32 (BUTYL ACETATE=1)
Solubility in Water:0
Appearance and Odor:VISCOUS LIQUID WITH AN ODOR CHARACTERISTIC OF THE
SOLVENTS LISTED
Percent Volatiles by Volume:45.5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG ALKALIES, STRONG MINERAL ACIDS, OR STRONG
OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:PRODUCES HAZ DECOMP PRODS WHEN
HEATED.WELDING/BRAZING/FLAME-CUTTING ON SURFS COATED W/PROD MAY
PRODUCE CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MATERIAL MUST BE DISPOSED OF IN ACCORDANCE
WITH FEDERAL, STATE, PROVINCIAL, AND LOCAL ENVIRONMENTAL CONTROL
REGULATIONS. EMPTY CONTAINERS SHOULD BE RECYCLED OR DISPOSED OF
THROUGH AN APPROVED WA STE MANAGEMENT FACILITY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ADHESIVE-SCOTCH-WELD (R) 2216 A GRAY
Kit Part:Y
Preparer's Name:C.A. EISENHARD
CAGE:76381
CAGE:04963
CAGE:60777
CAGE:76381
============= Composition/Information on Ingredients =============
Ingred Name:AMIDE
Fraction by Wt: 61%
Other REC Limits:NONE SPECIFIED
Ingred Name:ALUMINUM SILICATE PIGMENT
CAS:1302-76-7
RTECS #:BD1450000
Fraction by Wt: 39%
Other REC Limits:NONE SPECIFIED
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5250000
Fraction by Wt: 1%
Other REC Limits:NONE SPECIFIED
ACGIH TLV:3.5 MG/M3
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:EXTREMELY IRRITATING TO EYES UPON
DIRECT CONTACT. MAY CAUSE PERMANENT EYE DAMAGE. MAY CAUSE SKIN
IRRITATION UPON PROLONGED CONTACT. MAY CAUSE SENSITIZATION IN SOME
INDIVIDUALS. VAPORS MAY BE IRRITATIN G TO RESPIRATORY SYSTEM. MAY
CAUSE GASTROINTESTINAL IRRITATION.
Effects of Overexposure:EYES:IRRITATING. SKIN:IRRITATING.MAY CAUSE
SENSITIZATION.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH PLENTY OF WATER FOR AT LEAST 10 MINUTES.
CONTACT A PHYSICIAN. SKIN:WASH THOROUGHLY WITH SOAP AND WATER.
INHALATION:PROVIDE FRESH AIR. SWALLOWED:DRINK TWO GLASSES OF WATER
OR MILK AND C ALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:+200F/+93C
Extinguishing Media:CO2, FOAM, DRY CHEMICAL, WATER
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR SELF-CONTAINED
BREATHING APPARATUS WHEN FIGHTING FIRES INVOLVING THIS MATERIAL.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. COLLECT SPILLED MATERIAL,
CLEANUP RESIDUE AND PLACE IN A METAL CONTAINER (U.S. DEPT OF
TRANSPORATION APPROVED IF IT IS TO BE SHIPPED).DISPOSE OF CLEANUP
MAT'L BY INCINERATION IN INDUST RIAL OR COMMERCIAL INCINERATOR.
======================Handling and Storage ======================
Handling and Storage Precautions:PREVENT CONTACT WITH EYES AND
SKIN.AVOID INHALATION OR EYE CONTACT WITH DUST FROM GRINDING
OPERATIONS ON THE CURED MAT'L.USE ONLY IN WELL VENTED AREA.
Other Precautions:CURING OVENS MUST BE VENTED TO THE OUTDOORS. WASH
CONTAMINATED CLOTHING BEFORE REUSE. KEEP CONTAINER CLOSED. KEEP OUT
OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Ventilation:LOCAL OR MECHANICAL EXHAUST.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.26
Viscosity:52,000 CPS
Solubility in Water:NOT SOLUBLE
Appearance and Odor:GRAY PASTE, NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO, CO2, N AND SMOKE PARTICLES WHEN
SUBJECTED TO EXCESSIVE HEAT OR FLAME.
==================== Disposal Considerations ====================
Waste Disposal Methods:SINCE REGULATIONS VARY, CONSULT APPLICABLE
REGULATIONS OR AUTHORITIES BEFORE DISPOSAL. TWO PART
SYSTEM:COMBINED PARTS (B & A) WHEN FULLY CURED, MAY BE DISPOSED IN
A SANITARY LANDFILL PER REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DOW CORNING HIGH VACUUM GREASE
CAGE:5D028
CAGE:5D028
CAGE:71984
============= Composition/Information on Ingredients =============
Ingred Name:SILICA GEL
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 9%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:POLY (DIMETHYLSILOXANE)
CAS:63148-62-9
RTECS #:JJ6484500
Fraction by Wt: 83%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYDIMETHYLSILOXANE
CAS:70131-67-8
Fraction by Wt: 7%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:MAY CAUSE MILD
IRRITATION.SKIN:SINGLE PROLONGED EXPOSURE(24-48 HOURS) IS UNLIKELY
TO CAUSE HARM.INGEST:LARGE AMOUNTS MAY CAUSE GI TRACT
IRRITATION.INHAL:NO INJURY EXPECTED FROM EXPOSURE OF LESS T HAN 8
HOURS.
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of Overexposure:EYES:REDNESS AND DRYNESS SIMILAR TO WINDBURN.
Medical Cond Aggravated by Exposure:UNLIKELY TO AGGRIVATE EXISTING
MEDICAL CONDITIONS UNDER NORMAL CONDITIONS OF USE.
======================= First Aid Measures =======================
First Aid:NO FIRST AID SHOULD BE NEEDED.TREAT SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point:212F,100C
Extinguishing Media:WATER FOG OR SPRAY,DRY CHEMICAL,CARBON
DIOXIDE,FOAM.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:FIRE CONDITIONS MAY EVOLVE TOXIC FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP WITH NON-COMBUSTIBLE INERT
ADSORBANT(EG.CLAY);PLACE COLLECTED MATERIAL IN AN APPROPRIATE
CONTAINER FOR DISPOSAL;CLEAN SPILL AREA TO REMOVE
SLIPPERINESS,USING SEVERAL MOPPINGS OR USING SOLVENTS ,HI PRESS
STEAM OR MILD CAUSTIC DTERGENTS.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY,WELL-VENTILATED
PLACE.KEEP CONTAINER CLOSED WHEN NOT IN USE.AVOID CONTACT WITH
OXIDIZING MATERIALS.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NEEDED IN NORMAL SERVICE.
Ventilation:USE GENERAL DILUTION VENTILATION.
Other Protective Equipment:PROVIDE A LOCAL EYE WASH STATION AND SAFETY
SHOWER.
Work Hygienic Practices:USE REASONABLE CARE IN HANDLING THIS
PRODUCT.WASH HANDS AFTER USE AND BEFORE EATING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:V7
Spec Gravity:1.1
Viscosity:2*10 6CST
Solubility in Water:NONE
Appearance and Odor:VISCOUS LIQUID,TRANSLUCENT WHITE,ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS MAY CAUSE A REACTION.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE,CARBON MONOXIDE,SILICON
DIXIDE,FORMALDEHYDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BRIGHT TOUCH INT ALKYD SEMI GLOSS,25/SERIES
CAGE:3Y107
CAGE:3Y107
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL SPIRITS.VAPOR PRESSURE:2 MMHG AT 68F,20C.
Other REC Limits:118 PPM
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE OR SKIN CONTACT MAY CAUSE
DISCOMFORT BY DEFATTING ACTION OF SOLVENT.REPEATED SKIN CONTACT MAY
CAUSE DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION:TEMPORARY
DIZZINESS,HEADACHE,POSSIBLE NAUSEA;SYMPTOMS DISAPPEAR WHEN EXPOSURE
CEASES.EYES:DISCOMFORT.SKIN:DISCOMFORT;DERMATITIS FROM REPEATED
CONTACT.INGESTION:N/K .
Medical Cond Aggravated by Exposure:RESPIRATORY AND CARDIOVASCULAR.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE PATIENT TO FRESH AIR.EYES:FLUSH WITH LARGE
AMOUNTS OF WATER FOR AT LEAST 15 MINUTES.SKIN:WASH THOROUGHLY AND
REMOVE SATURATED CLOTHING.IF SYMPTOMS PERSIST,GET MEDICAL
ATTENTION.INGES TION:CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:105F;41C
Lower Limits:0.7%
Upper Limits:N/K
Extinguishing Media:FOAM,CARBON DIOXIDE,DRY CHEMICAL,WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
.COOL EXPOSED CNTNRS W/ WATER SPRAY TO REDUCE PRESS.AVOID BRTHING
VAPORS.FIGHT AS VOLATILE LIQUID FIRE.
Unusual Fire/Explosion Hazard:KEEP AWAY FROM HEAT,SPARKS AND OPEN
FLAME.HAZARDOUS DECOMP PROD:CARBON DIOXIDE,CARBON MONOXIDE,POSSIBLE
ACROLEIN.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION AND PROVIDE
VENTILATION.LARGE SPILLS:SCOOP UP WITH NON-SPARKING TOOLS.PROVIDE
RESPIRATORY PROTECTION IF REQUIRED.SMALL SPILLS:PICK UP WITH
ABSORBENT MATERIALS.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HEAT,SPARKS,AND OPEN
FLAME.AVOID PROLONGED SKIN CONTACT.DO NOT BREATHE SPRAY MIST.
Other Precautions:GROUND CNTNRS WHEN POURING;KEEP FREE FALL < A FEW
INCHES TO PVNT STATIC SPARKS.AVOID SPONTANEOUS COMBUST OF CONTAMED
RAGS & EASILY IGNIT ORG ACCUM BY IMMED IMMERSION IN WATER.EMPTY
CNTNRS RETAIN HAZ P ROPERTIES.DO NOT WELD,(SEE SUPP DATA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .RESPIRATOR ORGANIC VAPORS.
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV
Other Protective Equipment:EYE WASH STATIONS AND SAFTY SHOWERS SHOULD
BE AVAILABLE.
Work Hygienic Practices:WASH HANDS AFTER USE,BEFORE EATING OR USING
WASHROOM.
Supplemental Safety and Health
WT/GAL:9.0.OTHER PRECAUTIONS:CUT OR PUNCTURE ON OR NEAR CNTNRS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:316-383F
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/K
Vapor Density:>AIR
Spec Gravity:1.0817
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:N/K
Appearance and Odor:N/K
Percent Volatiles by Volume:45.7%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXTREME HEAT OR HIGH HUMIDITY.
Hazardous Decomposition Products:CARBON DIOXIDE,CARBON MONOXIDE AND
POSSIBLE ACROLEIN.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .PLACE IN CLOSED CONTAINERS FOR
DISPOSAL.INCINERATE OR USE SECURE LANDFILL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:1010, MCP
CAGE:MOORE
CAGE:MOORE
============= Composition/Information on Ingredients =============
Ingred Name:NON HAZARDOUS INGREDIENTS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE ORAL TOXICITY:NONE. SKIN
IRRITATION: NONE. PRIMARY EYE IRRIT:NONE. ACUTE SKIN
TOXICITY:UNLIKELY. ACUTE INHALATION TOXICITY:NOT APPLICABLE.
CORROSIVITY:NONE. SENSITIVITY:NONE KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NONE KNOWN
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDAITELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, WATER
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE REQUIRED.
Other Precautions:NONE REQUIRED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED.
Ventilation:MECHANICAL (GENERAL) VENTILATION IS REQUIRED.
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:NONE REQUIRED.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:WHITE OR COLORED PAPER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
Hazardous Decomposition Products:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
ENVIRONMENTAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HYDROFLUORIC ACID 70 %;PROD.CODE:16-04363-0
Preparer's Name:GENE TURNER
CAGE:09531
CAGE:60777
CAGE:09531
============= Composition/Information on Ingredients =============
Ingred Name:HYDROGEN FLUORIDE (SARA III)
CAS:7664-39-3
RTECS #:MW7875000
Fraction by Wt: 70.0%
OSHA PEL:3 PPM/6 STEL (F)
ACGIH TLV:C 3 PPM (F); 9192
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: BALANCE
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION CAN CAUSE COUGHING,
CHOKING, & INFLAMATION OF THE RESPIRATORY TRACT. SWALLOWING CAN
CAUSE BURNS TO MOUTH & G.I. TRACT. EYE CONTACT CAN CAUSE SEVERE
BURNS & DAMAGE. SKIN CONTACT CAN CA USE SEVERE BURNS AND DEEP
PENETRATION. CHRONIC: BONE AND JOINT CHANGES(FLUOROSIS) KIDNEY AND
LIVER DAMAGE,DEATH POSSIBLE
Explanation of Carcinogenicity:DATA PER MSDS
Effects of Overexposure:EYES & SKIN-CAN CAUSE IRRIT & SEVERE BURNS.
INGEST-SEVERE BURNS,POSSIBLE FATAL HYPOCALCEMIA W/O MED
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
FOR 15 MINUTES HOLDING EYELIDS OPEN. GET IMMEDIATE MEDICAL
ATTENTION. S KIN:REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND
WATER. GET IMMEDIATE MEDICAL ATTENTION. INGESTION:DO NOT INDUCE
VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET IMMEDIATE
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:SUITABLE AGENT FOR MATL NEAR FIRE
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:REACTION W/CERTAIN METALS GENERATES FLAM
& POTENT EXPLOS HYDROGEN GAS.HEAT EVOLVES ON CONT W/MANY S
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILL: FLUSH WITH WATER AND NEUTRALIZE
WITH ALKALINE MATERIAL. SEWER NEUTRALIZED MATERIAL WITH EXCESS
WATER. LARGE SPILL: EVACUATE AND VENTILATE AREA. IF POSSIBLE, STOP
LEAK. DIKE TO RETAIN RUN OFF. NEUTRALIZE & PICK UP WITH ABSORBENT
MATERIAL.
Neutralizing Agent:SODA ASH, LIME OR OTHER SUITABLE ALKALINE MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT
CONTAINERS FROM PHYSICAL DAMAGE & DIRECT SUNLIGHT.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE MIST. AVOID
PROLONGED OR REPEATED BREATHING OF VAPOR. AVOID CONTACT WITH EYES.
USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL(TLV), USE NIOSH/MSHA APPROVED FULL FACEPIECE
CHEMICAL CARTRIDGE RESPIRATOR OR A SUPPLIED AIR FULL FACEPIECE
RESPIRATOR OR AIRLINED HOOD.
Ventilation:A SYSTEM OF LOCAL EXHAUST IS RECOMMENDED TO KEEP EMPLOYEE
EXPOSURES BELOW THE TLV.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
IMPERVIOUS BOOTS, APRON, OR COVERALLS AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS. PROTECT FROM MOISTURE.
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:152F,67C
Vapor Pres:110 MMHG
Vapor Density:2.21
Spec Gravity:1.258
Evaporation Rate & Reference:<1 (BUTYL ACET=1)
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQ,SHARP PUNGENT ODOR;FUMES IN AIR
Percent Volatiles by Volume:100.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CARBONATES,SULFIDES & CYANIDES,ALKALIES & SOME OXIDES
Stability Condition to Avoid:GLASS,CONCRETE & SILICON-BEARING MATLS
Hazardous Decomposition Products:BOILS AWAY AS HYDROGEN FLUORIDE GAS &
WATER
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS. DISPOSE
IN A RCRA-APPROVED WASTE FACILITY .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:RING-TILE LUBRICANT
CAGE:19853
CAGE:19853
============= Composition/Information on Ingredients =============
Ingred Name:NON HAZARDOUS INGREDIENT
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:NONE.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH WITH WATER FOR AT LEAST 15 MINUTES. IF DISCOMFORT
PERSISTS, CALL MD. SKIN:FLUSH WITH COPIOUS AMOUNTS OF WATER. CALL
MD . INHAL:MOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O2/ARTF RESP)
. INGEST:CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:NOT APPLICABLE. USE MEDIA SUITABLE FOR SURROUNDING
FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH WITH WATER OR WIPE UP WITH PAPER TOWELS
OR CLOTH.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED.
Ventilation:NONE REQUIRED.
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:STANDARD.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.06 (H2O=1)
Solubility in Water:APPRECIABLE
Appearance and Odor:TAN COLORED PASTE, MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH TO SEWER OR DISPOSE IN LANDFILL. DISPOSAL
MUST BE IN ACCORDANCE WITH FEDERAL, STATE, AND LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:35-A WHITE OPAQUE CLEAR PRINT STAMP PAD INK
CAGE:88303
CAGE:88303
============= Composition/Information on Ingredients =============
Ingred Name:BUTYRIC ACID LACTONE, TETRAHYDRO-2-FURANONE, BLO
BUTYRYLACTONE
CAS:96-48-0
RTECS #:LU3500000
Fraction by Wt: 61.11%
Ingred Name:PIGMENTS
Fraction by Wt: 27.78%
Ingred Name:RESIN
Fraction by Wt: 27.78%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PAINFUL STINGING/BURNING/WATERING OF
EYES/CONJUNCTIVITIS/OPAQUENESS OF CORNEA/POSSIBLE LOSS OF SIGHT.
SKIN: SLIGHT ANALGESIC EFFECT. SIGNIFICANT AMOUNT ABSORBED
DERMALLY/NARCOSIS. SWALLOWING CAN CAUSE GI
IRRITATION/NAUSEA/VOMITING/DIARRHEA. MAY DULL SENSES. EXPOSED TO
HIGH CONCENTRATIONS, MAY CAUSE NARCOSIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:PAINFUL STINGING/BURNING/WATERING OF
EYES/CONJUNCTIVITIS/OPAQUENESS OF CORNEA/POSSIBLE LOSS OF SIGHT.
SKIN: SLIGHT ANALGESIC EFFECT. SIGNIFICANT AMOUNT ABSORBED
DERMALLY/NARCOSIS. SWALLOWING CAN CAUSE GI
IRRITATION/NAUSEA/VOMITING/DIARRHEA. MAY DULL SENSES. EXPOSED TO
HIGH CONCENTRATIONS MAY CAUSE NARCOSIS.
======================= First Aid Measures =======================
First Aid:SKIN: THOROUGHLY WASH W/SOAP & WATER. EYES: FLUSH W/PLENTY OF
WATER FOR 15 MINS. INGESTION: GIVE 2 GLASSES OF WATER, INDUCE
VOMITING IMMEDIATELY BY STICKING FINGER DOWN THROAT. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. INHALATION: REMOVE TO
FRESH AIR. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:OC
Flash Point:208F
Lower Limits:1.4
Upper Limits:6.9
Extinguishing Media:WATER, ALCOHOL FOAM, DRY CHEMICAL/CO2
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: ABSORB LIQUID ON ABSORBANT MATERIAL &
TRANSFER TO HOOD. LARGE: ELIMINATE ALL IGNITION SOURCES. EVACUATE
AREA. STOP AT SOURCE, DIKE AREA & PUMP LIQUID TO SALVAGE TANK. TAKE
UP REMAINING LIQUID W /ABSORBENT MATERIAL & SHOVEL INTO CONTAINRS.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTAINERS MAY BE HAZARDOUS WHEN
EMPTIED. EMPTY CONTAINERS RETAIN PRODUCT RESIDUES, PRECAUTIONS MUST
BE OBSERVED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV IS EXCEEDED, A NIOSH/MSHA APPROVED AIR
SUPPLIED RESPIRATOR IS ADVISED.
Ventilation:MECHANICAL (GENERAL & LOCAL EXHAUST) TO MAINTAIN EXPOSURE
BELOW TLVS.
Other Protective Equipment:IMPERVIOUS CLOTHING & BOOTS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:399F
Vapor Pres:<1
Vapor Density:3
Evaporation Rate & Reference:(N-BU AC=1): <1
Solubility in Water:61.11 W/T
Appearance and Odor:WHITE LIQUID, AMINE-LIKE ODOR.
Percent Volatiles by Volume:61.11
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
Hazardous Decomposition Products:CO2, CO, HYDROGEN CHLORIDE, VARIOUS
HYDROCARBONS
==================== Disposal Considerations ====================
Waste Disposal Methods:SMALL: EVAPORATE INTO HOOD, COMPLETELY CLEAR
HOOD DUCT WORK. LARGE: DESTROY BY LIQUID INCINERATION. CONTAMINATED
ABSORBENT MAY BE DEPOSITED IN A LANDFILL BY LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:5962/BF101
CAGE:91491
CAGE:91491
============= Composition/Information on Ingredients =============
Ingred Name:CARBON 14
===================== Hazards Identification =====================
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
======================= First Aid Measures =======================
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
===================== Fire Fighting Measures =====================
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
================== Accidental Release Measures ==================
======================Handling and Storage ======================
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
SOURCE OF DATA-MIL HANDBOOK 600-1 SEP 76.SAFETY & HEALTH DATA DEVELOPED
BY DGSC-STF.
================== Physical/Chemical Properties ==================
HCC:A3
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-IN ACCORDANCE WITH
DOD REGULATIONS AND FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:COATING COMPOUND, METAL PRETREATMENT, RESIN
Kit Part:Y
CAGE:0GB20
CAGE:0GB20
============= Composition/Information on Ingredients =============
Ingred Name:POLYVINYL BUTYRAL (SARA III) (VAPOR PRESSURE 0.0 MM HG @
20C)
CAS:63148-65-2
RTECS #:TR4955000
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
Ingred Name:BUTYL ALCOHOL (SARA III) (VAPOR PRESSURE 5.9 MM HG @ 20C)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: <25%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL ALCOHOL (VAPOR PRESSURE 53.9 MM HG @ 20C)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: <65%
Other REC Limits:NONE SPECIFIED
ACGIH TLV:1000 PPM
Ingred Name:CHROMIUM (SARA III) (VAPOR PRESSURE 0.0 MM HG @ 20C)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:ACUTE TOXICITY: OVEREXPOSURE CAN LEAD
TO CENTRAL NERVOUS SYSTEM DEPRESSION (HEADACHE, DIZZINESS, NAUSEA,
UNCONSCIOUSNESS). EYE: SLIGHT IRRITATION. TESTS SHOW OVEREXPOSURE
MAY CAUSE BLOOD DISORDERS AND NEUROLOGIC DISORDERS. INTENTIONAL
MISUSE OF THIS PRODUCT MAY BE HARMFUL OR FATAL.
Explanation of Carcinogenicity:THIS PRODUCT CONTAINS A SUSPECTED
(CHROMIUM) CARCINOGEN.
Effects of Overexposure:CHRONIC: EYE: PROLONGED & REPEATED CONTACT MAY
BE MORE THAN SLIGHTLY IRRITATING. SKIN: PROLONGED & REPEATED LIQ
CONTACT CAN CAUSE DEFATTING & DRYING WHICH MAY RESULT IN SKIN
IRRITATION & DERMATITIS. R EPORTS ASSOCIATE REPEATED & PROLONGED
OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN &
NERVOUS SYSTEM DAMAGE
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/WATER 15 MIN HOLD EYELIDS OPEN. GET MED AID.
SKIN: WASH W/SOAP & WATER. REMOVE CONTAMINTD CLOTHING & SHOES. DONT
REUSE TILL CLEANED. IF PERSISTENT IRRIT OCCURS, GET MED AID.
INHALE: REMOV E TO FRESH AIR. GIVE OXYGEN IF BREATHING DIFFICULT,
ARTIFICIAL RESPIRATION IF NOT BREATHING. GET MED AID. INGEST: GET
MED AID. NOTHING BY MOUTH TO UNCONSCIOUS. INDUCE VOMIT-IPECAC:1 OZ
THEN 8 OZ WATER
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:60.0F,15.6C
Lower Limits:1.4
Upper Limits:19.0
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, FOAM
Fire Fighting Procedures:EVACUATE HAZARD AREA. WEAR PROTECTIVE CLOTHES
INCLUDING NIOSH SCBA. COOL FIRE EXPOSED CONTAINER W/WATER. AVOID
SPREADING BURNING LIQUID W/WATER USED FOR COOLING
Unusual Fire/Explosion Hazard:THIS MATERIAL IS FLAMMABLE AND MAY BE
IGNITED BY HEAT, SPARKS, FALME OR STATIC ELECTRICITY.
================== Accidental Release Measures ==================
Spill Release Procedures:STAY UPWIND AND AWAY FROM SPILL. KEEP ALL
SOURCES OF IGNITION & HOT METAL SURFACES AWAY FROM SPILL. IF SPILL
IS INDOORS, VENT AREA. IF LARGE SPILL, CALL SPILL ERSPONSE TEAM.
NOTIFY APPROPRIATE STATE A ND LOCAL AGENCIES.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS, & OPEN
FLAME. KEEP CONTAINER CLOSED. STORE AWAY FROM STRONG OXIDIZERS IN
COOL, DRY PLACE WITH EXPLOSION PROOF VENTILATION
Other Precautions:GROUND EQUIPMENT TO PREVENT ACCUMULATION OF STATIC
CHARGE. IF POURING OR TRANSFERRING MATERIALS GROUND & BOND
CONTAINERS. DO NOT WELD, HEAT OR DRILL NEAR/ON CONTAINER, EVEN
EMPTIED CONTAINERS CAN CONT AIN EXPLOSIVE VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DEPENDING ON THE NATURE & CONCENTRATION OF
AIRBORNE MATERIAL, USE RESPIRATOR OR GAS MASK WITH APPROPRIATE
CARTRIDGES AND CANNISTERS (NIOSH APPROVED, IF AVAILABLE) OR
SUPPLIED AIR EQUIPMENT.
Ventilation:USE EXPLOSION PROOF VENT TO CONTROL VAPOR CONCENTRATIONS.
ADDED VENT/EXHAUST TO MAINTAIN BELOW TLV.
Other Protective Equipment:WEAR PROTECTIVE CLOTHING AS REQUIRED TO
PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH WITH SOAP & WATER BEFORE EATING, DRINKING,
SMOKING, OR USING TOILET. WASH CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:165 TO 244F
Vapor Density:> AIR
Spec Gravity:7.5 LBS/GAL
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Percent Volatiles by Volume:89.6
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH ALKALIES, AQUEOUS ACIDS, AMINES, AND ACIDIC
ALCOHOLS. AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID HEAT, SPARKS, AND OPEN FLAME.
Hazardous Decomposition Products:THERMAL DECOMPOSITION IN THE PRESENCE
OF AIR MAY YIELD CARBON MONOXIDE, AND/OR CARBON DIOXIDE.
Conditions to Avoid Polymerization:AVOID HEAT, SPARKS, AND OPEN FLAME.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF PRODUCT IN ACCORDANCE WITH LOCAL,
STATE, AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LANTHANUM OXIDE, LA64
Preparer's Name:SUSHA RAMANC
CAGE:04XT3
CAGE:04XT3
============= Composition/Information on Ingredients =============
Ingred Name:LANTHANUM OXIDE; (LA*2O*3)
CAS:1312-81-8
RTECS #:ES3300000
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:15 MG/M3 (DUST)(MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT): >10,000 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:LANTHANUM OXIDE MAY BE HARMFUL IF
INHALED, INGESTED OR CONTACTED WITH THE SKIN OR EYES. IT CAN
IRRITATE THE SKIN OR EYES IF CONTACT OCCURS. CHRONIC EXPOSURE TO
HIGH CONCENTRATIONS MAY CAUSE DAMAGE TO MUCOUS MEMBRANES AND
RESPIRATORY TRACT.STUDIES HAVE SHOWN LANTHANUM TO PRODUCE
ANTICOAGULANT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:EFFETS ON LABORATORIES ANIMALS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MIN OCCASIONALLY LIFTING
UPPER & LOWER EYELIDS. SKIN: REMOVE CONTAMD CLOTHING, THEN FLUSH
W/WATER FOR AT LEAST 15 MIN. WASH CLOTHING THOROUGHLY BEFORE REUSE.
INHAL: MOVE TO FRESH AIR. INGEST: DO NOT INDUCE VOMITING. GET
IMMEDIATE MEDICAL HELP. IF THE PATIENT IS CONSCIOUS, GIVE A LARGE
QUANTITIES OF WATER OR MILK. IF IRRITATION CONTINUES, GET MEDICAL
ATTN IMMED.
===================== Fire Fighting Measures =====================
Extinguishing Media:APPROPRIATE TO SURROUNDING FIRE CONDITIONS.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:REACTS VIOLENTLY WITH ACIDS.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. DILUTE SPILL WITH WATER AND
NEUTRALIZE WITH SODA ASH, LIMESTONE ETC. WIPE UP AND PUT INTO A
SEALED CONTAINER FOR PROPER DISPOSAL. WASH SPILL SITE OFF WITH
WATER AFTER MATERIAL PICK UP IS COMPLETE.
Neutralizing Agent:SODA ASH, LIMESTONE ETC.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY AREA IN A TIGHTLY
SEALED CONTAINER.
Other Precautions:WHEN USED FOR GLASS POLISHING, THE SUSPENSIONS OF
POLISH BECOMES ALKALINE PH> OR = TO 8.5 FOLLOWING THE HYDROLYSIS OF
SKIN & EYES. AV OID INHAL, INGEST, CNTC W/EYES & SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATORY.
Ventilation:CHEMICAL FUME HOOD.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . LAB COAT. CHEMICAL RESISTANT CLOTHING.
Work Hygienic Practices:WASH CAREFULLY AFTER USE.
Supplemental Safety and Health
SOL IN H*2O: COLD - 0.0004 G/CC: HOT-DECOMPOSES.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:4185F,2307C
Spec Gravity:5.87
Solubility in Water:SUPDAT
Appearance and Odor:WHITE, ODORLESS POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NOT APPLICABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT FEDERAL, STATE AND LOCAL HAZARDOUS OR
CHEMICAL WASTE DISPOSAL AGENCY FOR REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:4170-9020 ALUMINUM COMP A, DEVRAN 4170 (SUP DAT)
CAGE:JO701
CAGE:JO701
CAGE:01PD6
============= Composition/Information on Ingredients =============
Ingred Name:EPOXY RESIN
CAS:25036-25-3
Fraction by Wt: 30-40%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:KAOLIN
CAS:1332-58-7
RTECS #:GF1670500
Fraction by Wt: 30-40%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST
Ingred Name:TOLUENE (SARA 313) (CERCLA)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 1-5%
OSHA PEL:200 PPM
ACGIH TLV:50 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE (SARA 313) (CERCLA)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 1-5%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE) (MEK) (SARA 313) (CERCLA)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 5-10%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM/300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-PENTANONE, 4-METHYL-; (METHYL ISOBUTYL KETONE) (SARA 313)
(CERCLA)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 5-10%
OSHA PEL:100 PPM
ACGIH TLV:50 PPM/75 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ALUMINUM (SARA 313)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 5-10%
OSHA PEL:15 MG/M3 DUST
ACGIH TLV:10 MG/M3 DUST
Ingred Name:SUP DAT: LEWIS ACIDS, CAUSTICS, MINERAL ACIDS, SODIUM,
POTASSIUM.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP: LT HEAD, NAUS, VOMIT, DIARR, GI DISTURBS,
ABDOM PAIN, APATHY, CNS DEPRESS, UNCON. CONTAINS (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: CHEM MOD TOX BY INGEST. CONTAINS CHEM TOX BY
INGEST. OTHER EFTS OF OVEREXP MAY INCL TOX TO LIVER, (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: KIDNEY, LUNGS, CNS, BLOOD, HEART. MAY BE ABSORBED
THRU SKIN. NOTICE: RPTS HAVE ASSOC RPTD & PRLNG OCCUP (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: OVEREXP TO SOLVS W/PERM BRAIN & NERV SYS DMG.
INTENTIONAL MISUSE BY DELIB CONCENTRATING & INHALING THE (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: CONTENTS MAY BE HARMFUL/FATAL. NUISANCE DUST
HAZ-OVEREXP MAY CAUSE MECH IRRIT OF EYES, SKIN, & RESP (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: TRACT. DELIB INHAL OF TOLUENE HAS BEEN ASSOC
W/NEONATAL EFTS IN HUMANS. DEVEL TOX HAS ALSO BEEN SHOWN (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: IN LAB ANIMALS EXPOSED TO TOLUENE BY INHAL.
ADDITIONALLY, DELIB INHAL OF TOLUENE MAY RSLT IN CARDIAC (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: SENSIT WHICH CAN CAUSE IRREG HEART RHYTHM & SUDDEN
DEATH. TOLUENE APPEARS ON NAVY OCCUP CHEM REPRO HAZ (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17: LIST. CONSULT APPROP HEALTH PROFESSIONALS
CONCERNING LATEST HAZ LIST INFO & SAFE HANDLING & EXPOS INFO .
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: IF IRRIT OCCURS, CONSULT MD. EYES: FLUSH
IMMED W/LGE AMTS OF WATER, ESP UNDER LIDS FOR AT LEAST (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19: 15 MIN. IF IRRIT OCCURS/OTHER EFTS PERSIST, OBTAIN
MED ATTN. INGEST: IF SWALLOWED, OBTAIN MED TREATMENT IMMED.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: EQUIP MUST BE USED DURING CLEANUP. LGE SPILL:
SHUT OFF LEAK IF SAFE TO DO SO. DIKE & CONTAIN SPILL. (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21: PUMP TO STOR/SALVAGE VESSELS. USE ABSORB TO PICK UP
EXCESS RESIDUE. KEEP SALVAGEABLE MATL & RINSE WATER (ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22: OUT OF SEWERS & WATER COURSES. SMALL SPILL: USE
ABSORBEBT TO PICK UP RESIDUE & DISPOSE OF PROPERLY.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: ABRADING (SANDING) PAINTED SURFS. IF SUCH
CNDTNS CANNOT BE AVOIDED, USE APPROP NIOSH APPRVD RESP AS (ING 25)
RTECS #:9999999ZZ
Ingred Name:ING 24: DIRECTED. EMPTY CONTRS MAY CONTAIN HAZ RESIDUES.
GROUND EQUIP WHEN TRANSFERRING TO PVNT ACCUM OF STATIC CHARGE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: IRRIT OF RESP TRACT.
PRLNG INHAL MAY LEAD TO MUC MEMB IRRIT, FATG, DROW, DIZZ &/OR LT
HEAD, HDCH, UNCOORD, NAUS, VOMIT, COUGHING, APATHY, CNS DEPRESS,
RESP PROBLEMS, INTOXICATION, CONFUS ION, ANESTH EFT/NARCOSIS, DFCLT
BRTHG, LIVER & KIDNEY DMG, PNEUMOCONIOSIS, LOSS OF CONSCIOUSNESS,
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: RESP FAILURE, ASPHY, DEATH. SKIN:
IRRIT. PRLNG/RPTD CONT CAN CAUSE DERM, DEFAT. POSS SENSIT. EYES:
IRRIT. PRLNG/RPTD CONT CAN CAUSE BLURRED VISION, TEARING, REDNESS,
SEV IRRIT, CORNEAL INJUR Y. INGEST: MAY CAUSE LUNG INFLAMM & DMGDUE
TO ASPIR OF MATL INTO LUNGS, MOUTH & THROAT IRRIT, DROW, DIZZ &/OR
(ING 10)
Medical Cond Aggravated by Exposure:EYE, SKIN, RESPIRATORY DISORDERS,
LUNG DISORDERS, ASTHMA-LIKE CONDITIONS, CARDIAC ABNORMALITIES,
KIDNEY DISORDERS, LIVER DISORDERS, NERVOUS SYSTEM DISORDERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED
BRTHG. GET EMER MED ATTN. HAVE TRAINED PERS GIVE OXYGEN IF NEC. GET
MED HELP FOR ANY BRTHG DFCLTY. REMOVE TO FRESH AIR IF INHAL CAUSES
EYE WATER ING, HDCH, DIZZ/OTHER DISCOMFORT. GET MED ATTN IF
DISCOMFORT/IRRIT PERSISTS. SKIN: FLUSH FROM SKIN W/WATER. THEN WASH
THORO W/SOAP & WATER. REMOVE CONTAM CLTHG & WASH BEFORE REUSE. (ING
19)
===================== Fire Fighting Measures =====================
Flash Point:49.0F,9.4C
Extinguishing Media:DRY CHEMICAL OR FOAM WATER FOG. CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL AND PROTECT EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CLSD CONTRS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT/FIRE. VAPS MAY IGNITE EXPLO AT AMBIENT TEMPS. VAPS ARE
HVR/AIR & MAY TRAVEL LONG DISTS TO SOURCE (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:COMPLY W/ALL APPLIC HLTH & ENVIRON REGS. ELIM
ALL SOURCES OF IGNIT. VENT AREA W/EXPLO-PROOF EQUIP. SPILLS MAY BE
COLLECTED W/ABSORB MATLS. USE NON-SPKG TOOLS. EVACUATE ALL UNNEC
PERS. PLACE COLLECTED MATL IN PROPER CONTR. COMPLETE PERS PROT
(ING 21)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE <80F. STORE <100F. STORE IN
ORIGINAL CONTRS. ISOLATED STORAGE DESIRABLE. KEEP AWAY FROM HEAT,
SPARKS & OPEN FLAME. USE ONLY W/ADEQUATE VENT.
Other Precautions:DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF
CHILDREN. AVOID CONT W/SKIN & EYES, & BRTHG OF VAPS. KEEP CONTRS
TIGHTLY CLSD & UPRIGHT WHEN NOT IN USE. AVOID CNDTNS WHICH RSLT IN
FORM OF INHALABLE PARTI CLES SUCH AS SPRAYING OR (ING 24)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE RESPIRATORY PROTECTION IS REQUIRED, USE
ONLY NIOSH APPROVED RESPIRATORS IN ACCORDANCE WITH OSHA STANDARD 29
CFR 1910.134.
Ventilation:PROVIDE DILUTION VENT/LOCAL EXHAUST TO PREVENT BUILD-UP OF
VAPORS. USE EXPLOSION-PROOF EQUIP. USE NON-SPARKING TOOLS.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA . IMPERVIOUS CLOTHING, APRON, BOOTS.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING,
ESPECIALLY BEFORE EATING OR SMOKING.
Supplemental Safety and Health
TRADE NAME/PART #: CORROSION-RESISTANT EPOXY PRIMER. EXPLO HAZ: OF
IGNIT & FLASH BACK. CLSD CONTRS MAY BURST IF EXPOSED TO EXTREME
HEAT/FIRE. MAY DECOMPOSE UNDER FIRE CNDTNS EMITTING IRRITANT &/OR
TOX GASES. MATLS TO AVOID: AMMONIA, VINYL POLYMERS, HYDRAZIDES,
MERCAPTANS, HALOGENATED CMPDS, MAGNESIUM, (ING 9)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>172F,>78C
Spec Gravity:1.36
VOC Pounds/Gallon:309
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:37.96
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, REDUCING AGENTS, BASES, ALDEHYDES, ISOCYANATES,
AMINES, ALUMINUM, ZINC, HYPOCHLORITES, (SUP DAT)
Stability Condition to Avoid:ELEVATED TEMPS, CONTACT W/OXIDIZING AGENT,
CONT W/ALUMINUM/ZINC, STOR NEAR ACIDS, SPARKS, OPEN FLAME. IGNITION
SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
AMMONIA, OXYGEN, ACIDIC GASES, ALDEHYDES, TOXIC GASES, UNIDENTIFIED
ORGANIC COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS. DISPOSE OF IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DP48LF EPOXY PRIMER
CAGE:DO542
CAGE:DO542
============= Composition/Information on Ingredients =============
Ingred Name:BARIUM SULFATE, BARYTES *96-2*
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: 10-15%
OSHA PEL:10 MG/CUM
ACGIH TLV:10 MG/CUM
Ingred Name:ZINC PHOSPHATE, ZINC ORTHOPHOSPHATE
CAS:7779-90-0
RTECS #:TD0590000
Fraction by Wt: 5-10%
Other REC Limits:10 MG/CUM
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM
Ingred Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
CARCINOGEN, IARC GROUP 3)*96-2*
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 15-20%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *96-2*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 2-5%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC, HIGH FLASH
AROMATIC NAPHTHA, C8&10 AROMATIC HYDROCARBON *96-2*
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 5-10%
Ingred Name:2-HEPTANONE, METHYL N-AMYL KETONE
CAS:110-43-0
RTECS #:MJ5075000
Fraction by Wt: 10-15%
Other REC Limits:50 PPM
OSHA PEL:465 MG/CUM
ACGIH TLV:233 MG/CUM
Ingred Name:TOLUENE (IARC CARC- GROUP 3) *96-2*
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 2-5%
Other REC Limits:375 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HEXONE, METHYL ISOBUTYL KETONE (MIBK), 4-METHYL-2-PENTANONE
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 5-10%
Other REC Limits:50 PPM
OSHA PEL:410 MG/CUM
ACGIH TLV:205 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-BUTOXYETHANOL (ETHYLENE GLYCOL MONOBUTYL ETHER), BUTYL
CELLOSOLVE, BUTYL GLYCOL, GLYCOL ETHER EB * 96-2 *
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 2-5%
Other REC Limits:25 PPM (SKIN)
OSHA PEL:50 PPM (SKIN)
ACGIH TLV:25 PPM (SKIN)
Ingred Name:FILM FORMERS, RESINS, AND ADDITIVES
Fraction by Wt: 2-5%
Ingred Name:BARIUM COMPOUNDS
Fraction by Wt: 10-15%
Ingred Name:GLYCOL ETHERS
Fraction by Wt: 2-5%
Ingred Name:BISPHENOL A DIGLYCIDYL ETHER RESIN, EPOXY RESIN, EPON 820,
ARALDITE 6004, AMINE ADDUCT, ARALDITE GY250 *96-2*
CAS:25068-38-6
RTECS #:KD4380000
Fraction by Wt: 10-15%
Ingred Name:CARBONIC ACID, CALCIUM SALT (1:1), CALCIUM CARBONATE,
DURAMITE
CAS:471-34-1
RTECS #:FF9335000
Fraction by Wt: 5-10%
Other REC Limits:10 MG/CUM (DUST)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF SWALLOWED, ABSORBED THROUGH
THE SKIN & INHALED. EYES: IRRITATION. SKIN: IRRITATION, ALLERGIC
REACTIONS. INHALATION: IRRITATION TO NOSE & THROAT. REPEATED
EXPOSURE TO VAPOR CONCENTRATIONS MA Y CAUSE IRRITATION OF THE
RESPIRATORY SYSTEM & PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, EYE WATERING, HEADACHES, NAUSEA,
DIZZINESS, LOSS OF COORDINATION, REDNESS, ITCHING, BURNING, VISUAL
DISTURBANCES, DRYNESS, CRACKING, SWELLING.
======================= First Aid Measures =======================
First Aid:INGESTION: DON'T INDUCE VOMITING. EYES: FLUSH IMMEDIATELY
W/PLENTY OF WATER FOR 15 MINS. SKIN: FLUSH W/WATER, FOLLOWED BY
WATERLESS CLEANER & SOAP. INHALATION: REMOVE TO FRESH AIR. GIVE CPR
IF NEEDED.INGESTION: CONTACT A POISON CONTROL CENTER & HAVE
MATERIAL SAFETY DATA SHEET INFORMATION AVAILABLE. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:80F
Lower Limits:1.2
Extinguishing Media:CO2, DRY CHEMICAL/UNIVERSAL AQUEOUS FILM FORMING
FOAM.
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. WATER SPRAY
MAY BE USED TO COOL CLOSED CONTAINERS. IF WATER IS USED, FOG
NOZZLES ARE PREFERABLE. WEAR SCBA.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIPMENT & OTHER IGNITION SOURCES. DON'T
APPLY TO HOT SURFACES. (SEE SUPP)
================== Accidental Release Measures ==================
Spill Release Procedures:USE MAXIMUM VENTILATION. ONLY PERSONNEL
REMOVE IGNITION SOURCES. TAKE UP W/SAWDUST, VERMICULITE/OTHER
ABSORBENT MATERIAL & PLACE INTO CO NTAINERS FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:GROUND CONTAINER WHEN POURING. AVOID
FREE FALL OF LIQUIDS IN EXCESS OF A FEW INCHES. DON'T STORE >120F.
Other Precautions:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING &
INHALING THE CONTENTS CAN BE HARMFUL/FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED AIR PURIFYING/AIR
SUPPLIED RESPIRATORS.
Ventilation:GENERAL DILUTION/LOCAL EXHAUST VENTILATION.
Other Protective Equipment:IMPERMEABLE APRON.
Supplemental Safety and Health
UNUSUAL FIRE CONT'D: CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT. TOXIC GASES MAY FORM WHEN PRODUCT IS CONTACTED BY
FLAME/HOT SURFACES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:230-381.2F
Vapor Pres:7.5
Vapor Density:>1
Spec Gravity:1.42
Evaporation Rate & Reference:(BU OAC =100): 78
Solubility in Water:4.5
Appearance and Odor:VISCOUS LIQUID W/CHARACTERISTIC ODOR OF THE
SOLVENTS LISTED.
Percent Volatiles by Volume:61.12
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, STRONG MINERAL ACIDS/STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAMES, ELECTRICAL
EQUIPMENT & OTHER IGNITION SOURCES. TEMP >120F.
Hazardous Decomposition Products:HEATED, WELDING, BRAZING/FLAME
CUTTING: CO, HYDROGEN CHLORIDE, CHLORINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. EMPTY CONTAINERS SHOULD BE RECYCLED/DISPOSED OF
THROUGH AN APPROVED WASTE MANAGEMENT FACILITY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:340, 340BIL (MIL-P-24377A)
CAGE:4B345
CAGE:4B345
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE (SARA III) (% IS MIN).
CAS:12001-29-5
RTECS #:CI6478500
Fraction by Wt: 30%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9394
Ingred Name:POLYTETRAFLUOROETHYLENE (PTFE, TEFLON)
CAS:116-14-3
RTECS #:KX4025000
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:EXPOUSRE TO PTFE FUMES ABOVE 500F CAN
CAUSE TEMPORARY FLU-LIKE SYMPTOMS.
Explanation of Carcinogenicity:CONTAINS A [1332-21-4] WHICH IS
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:NONE. IMMED LONG TERM EXOSURE TO ASBESTOS CAN
CAUSE MESOTHELIOMA (A LUNG DISEASE).
Medical Cond Aggravated by Exposure:RESPIRATORY DISEASE.
======================= First Aid Measures =======================
First Aid:REMOVE TO FRESH AIR IF EXPOSED TO PTFE FUMES.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:NONE SPECIFIED BY MANUFACTURER. HOWEVER USE
APPROPRIATE EXT MEDIA FOR SURROUNDING FIRE/MATERIALS.
Fire Fighting Procedures:NONE REQUIRED.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:NORMAL CLEANUP.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE.
Other Precautions:AVOID CREATING DUST AND FUMES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELECT APPROPRIATE RESPIRATORY PROTECTION FROM
TABLE I OF 1910.1001 BASED ON EMPLOYEE EXPOSURE.
Ventilation:NOEN REQUIRED.
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:AVOID CREATING DUST AND FUMES.
Supplemental Safety and Health
PER "ORDER FOR SUPPLIES/SERVICES"SUBMITTED W/MSDS FROM DISC-EEM ITEM IS
"ASBESTOS, TEFLON IMPREGNATED PACKING".
================== Physical/Chemical Properties ==================
HCC:T6
Spec Gravity:1.5
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE TO GREYISH SHINY ROPE.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND ALKALIES.
Stability Condition to Avoid:AVOID TEMP ABOVE 600F.
Hazardous Decomposition Products:TETRAFLUOROETHYLENE FROM 800F,
HEXAFLUOROPROPYLENE FROM 850F AND CARBONYL FLUORIDE FROM 930F.
==================== Disposal Considerations ====================
Waste Disposal Methods:AS REQUIRED BY STATE, FEDERAL, LOCAL AGENCIES.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:LASER JET TONER CARTRIDGE C3903A, C3903A
CAGE:18660
CAGE:18660
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE ACRYLATE COPOLYMER
CAS:25153-46-2
Fraction by Wt: 45-55%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:IRON OXIDE
CAS:1317-61-9
Fraction by Wt: 45-55%
OSHA PEL:10 MG/M3
ACGIH TLV:5 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL, RAT) >5000 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: NOT APPLICABLE ROUTE OF
ENTRY FOR INTENDED USE. INHALATION: MINIMAL RESPIRATORY TRACT
IRRITATION MAY OCCUR AS WITH EXPOSURE TO LARGE AMOUNTS OF ANY
NON-TOXIC DUST. EYES: MAY CAUSE IRRITATIO N. SKIN: UNLIKELY TO
CAUSE IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGESTION: DILUTE STOMACH CONTENTS WITH SEVERAL GLASSES OF
WATER. INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH WITH RUNNING
WATER FOR AT LEAST 15 MINUTES. SKIN: WASH WITH SOAP AND WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, WATER, DRY CHEMICALS.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:TONER MATERIAL, LIKE MOST ORGANIC
MATERIAL IN POWDER FORM, IS CAPABLE OF CREATING A DUST EXPLOSION.
================== Accidental Release Measures ==================
Spill Release Procedures:NO TONER SPILLAGE OCCURS IN NORMAL OPERATION
OR HANDLING. IF IT SHOULD OCCUR, AVOID INHALATION OF THE DUST.
SWEEP MATERIAL ONTO PAPER AND CAREFULLY TRANSFER TO A SEALABLE
WASTE CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN. KEEP
AWAY FROM CONTACT WITH STRONG OXIDIZING MATERIALS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER INTENDED USE. USE NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT UNDER
INTENDED USE.
Other Protective Equipment:NOT REQUIRED UNDER INTENDED USE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:>212F,>100C
Spec Gravity:1.4-1.8(H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK FINE POWDER; SLIGHT PLASTIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:COMBUSTION WILL PRODUCE CARBON DIOXIDE
AND POSSIBLE TOXIC CHEMICALS SUCH AS CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS PRODUCT IS CONSTRUCTED FROM PLASTICS AND
METALS. THE WASTE TONER COULD BE CONSIDERED AS PLASTIC WASTE.
DISPOSAL SHOULD BE SUJBECT TO FEDERAL, STATE AND LOCAL LAWS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:1A0-6080 PLASTI-GRIT TYPE I (50 LB BAG)
CAGE:98231
CAGE:98231
============= Composition/Information on Ingredients =============
Ingred Name:POLYESTER
Fraction by Wt: 99.5%
Ingred Name:POLYESTER THERMOPLASTIC
CAS:30662-91-0
Fraction by Wt: <0.5%
Ingred Name:STEARAMIDOPROPYLDIMETHYL-BETA-HYDROXYETHYL AMMONIUM NITRATE
(QUATERNARY AMMONIUM COMPOUND)
CAS:2764-13-8
Fraction by Wt: <0.5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: IRRITATION. INHALATION:
RESPIRATORY TRACT IRRITATION. INGESTION: HARMFUL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN/EYES: IRRITATION. INHALATION: RESPIRATORY
TRACT IRRITATION. INGESTION: HARMFUL.
======================= First Aid Measures =======================
First Aid:SKIN: WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH W/WATER FOR
15 MINS. INHALATION: REMOVE TO FRESH AIR. INGESTION: INDUCE
VOMITING BY GIVING TWO GLASSES OF WATER. OBTAIN MEDICAL ATTENTION
IN ALL CASES .
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, DRY CHEMICAL, CO2, WATER, STEAM
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS & FULL
PROTECTIVE CLOTHING. WEAR A FULL FACE PIECE.
Unusual Fire/Explosion Hazard:POWDER FORMS EXPLOSIVE MIXTURE W/AIR.
SEALED (CLOSED) CONTAINERS CAN BUILD UP PRESSURE IF EXPOSED TO HEAT
(FIRE).
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP & PLACE IN APPROPRIATE DISPOSAL
CONTAINER. USE PROPER SAFETY EQUIPMENT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED, PROPERLY LABELED
CONTAINERS IN COOL VENTILATED AREA. KEEP AWAY FROM HEAT, OPEN
FLAMES, & OXIDIZING AGENTS.
Other Precautions:DON'T TRANSFER TO UNMARKED CONTAINERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR AN APPROVED NIOSH/MSHA PROPERLY FITTED DUST
RESPIRATOR.
Ventilation:PROVIDE MECHANICAL/LOCAL EXHAUST VENTILATION TO KEEP <TLV.
Other Protective Equipment:FACESHIELD, PROTECTIVE RUBBER APRON, SHOES
OR BOOTS
Work Hygienic Practices:WASH THOROUGHLY BEFORE EATING, SMOKING, OR
APPLYING COSMETICS. REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:1.25
pH:4-8
Solubility in Water:INSOLUBLE
Appearance and Odor:GRANULAR, NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT, FIRE, OPEN FLAMES
Hazardous Decomposition Products:CO, CO2, SMOKE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A SANITARY LANDFILL IN ACCORDANCE
W/LOCAL, STATE, & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: CHEMLOK 253X
Cage: DO802
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: DO802
Box: 10038
Cage: 30676
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EMERGENCY OVERVIEW: BLACK LIQ, W/SOLV ODOR. FLAM LIQ &
VAP. MAY CAUSE SKIN & EYE IRRIT. MAY CAUSE RESP TRACT IRRIT. VAP HARMFUL;
MAY AFFECT THE BRAIN/NERVOUS SYS CAUSING DIZZ, HDCH/NAUS. ACUTE: EYE CN
TCT:MAY CAUSE EYE IRRIT. SKIN CNTCT:MAYCAUSE IRRIT. MAY CAUSE DERM.
INHAL:POSS IRRIT OF THE RESP (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ:SYS CAN OCCUR CAUSING A VARIETY
OF SYMPS SUCH AS DRYNESS OF THE THROAT, TIGHTNESS OF THE CHEST, &
SHORTNESS OF BRTH. MAY CAUSE CNS DEPRESS CHARACTERIZED BY THE FOLLOWING
PROGRESSIVE STEPS: HD CH, DIZZ, STAGGERING GAIT, CONFUSN,
UNCONSCIOUSNESS/COMA. MAY CAUSE HDCH & NAUS. IN ELEVATED-TEMP (SUPDAT)
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYE:FLUSH IMMED W/LRG AMTS OF H*2O FOR AT LEAST 15 MIN HOLDING
EYELIDS OPEN WHILE FLUSHING, GET PROMPT MED ATTN. SKIN:FLUSH CONTAMD SKIN
W/LRG AMTS OF H*2O WHILE REMOVING CONTAMD CLTHG. WASH AFFECTED SKIN AREAS
W/SOAP & H*2O. GET MED ATTN IF SYMPS OCCUR. INHAL:MOVE PERS TO FRESH AIR.
RESTORE & SUPPORT CONTINUED BRTHG. IF BRTHG IS DFCLT, GIVE OXYGEN. GET
IMMED MED ATTN. INGEST:DO NOT
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: KEEP NON-ESSNTL PERS A SAFE DISTANCE AWAY FROM THE
SPILL AREA. REMOVE ALL SOURCES OF IGNIT (FLAME, HOT SURFS, & ELEC,
STATIC/FRICTIONAL SPARKS). AVOID BRTHG VAPS. USE NIOSH APPROVED
SELF-CONTAINED BRT HG EQUIP. NOTIFY APPROP AUTH IF NEC.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL SHOULD BE DONE IN ACCORDANCE WITH FEDERAL
(40CFR PART 261), STATE AND LOCAL ENVIRONMENTAL CONTROL REGULATIONS. IF WASTE
IS DETERMINED TO BE HAZARDOUS, USE LICENSED HAZARDOUS WASTE TRANSPORTER AND
DISPOSAL FACILITY.
Handling And Storage Precautions: DO NOT STORE/USE NEAR HEAT, SPARKS/OPEN
FLAME. REFER TO OSHA 29CFR PART 1910.106 "FLAMMABLE & COMBUSTIBLE
LIQUIDS" FOR SPECIFIC STORAGE REQ.
Other Precautions: STORE ONLY IN WELL-VENT AREAS. DO NOT PUNCTURE, DRAG/SLIDE
CNTNR. KEEP CNTNR CLSD WHEN NOT IN USE. KEEP CLOSURE TIGHT & CNTNR
UPRIGHT TO PVNT LEAKAGE. GROUND & BOND CNTNRS WHEN TRANSFERRING MATL.
AVOI D SKIN & EYE CNTCT. AVOID
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: SCC
Flash Point Text: 80.0F,26.7C
Lower Limits: 1.0%
Upper Limits: 7.0%
Extinguishing Media: CO*2, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures: USE NIOSH APPRVD SCBA & FULL PROT EQUIP (FP N).
WATER SPRAY MAY BE INEFT. IF H*2O IS USED, FOG NOZZLES ARE PREF. DURING A
FIRE, IRRIT &/TOX GASES & (SUPDAT)
Unusual Fire/Explosion Hazard: FLAMM LIQ & VAP. KEEP CNTNRS TIGHTLY CLSD.
ISOLATE FROM HEAT, ELEC EQUIP, SPARKS, OPEN FLAME, & OTHER SOURCES OF
IGNIT. CLSD CNTNRS MAY RUPTURE (SUPDAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE A NIOSH APPRVD CHEM/MECH FILTER RESP DESIGNED TO
REMOVE A COMBINATION OF PARTICULATES & ORG VAP IF OCCUP LIM ARE EXCEEDED.
FOR EMER SITUATIONS, CONFINED SPACE USE/OTHER CNDTNS WHERE EXPOS LIM MAY BE
GREATLY EXCEEDED, USE A
Ventilation: SUFFICIENT VENT IN PATTERN & VOL SHOULD BE PROVIDED IN ORDER
TO MAINTAIN AIR CONTAM LEVELS BELOW REC
Other Protective Equipment: ANSI APPRVD EMER EYE WASH & DELUGE SHOWER (FP N).
USE DISPOSAL/IMPERVIOUS CLTHG IF WORK CLTHG CONTAM IS
Work Hygienic Practices: WASH HANDS BEFORE EATING, SMOKING/USING TOILET
FACILITY. DO NOT SMOKE IN ANY CHEM HNDLG/STRG AREA. FOOD
Supplemental Safety and Health: USE OF "L" VERSION OF SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). FIRE FIGHT PROC:PARTICULATE MAY BE GENERATED
BY THERMAL DECOMP/COMBUST. EXPLO HAZ:WHEN EXPOSED TO EXTREME HEAT. USE WATER
SPRAY TO KEEP FIRE EXPOSED CNTNRS COOL.EFTS OF OVEREXP:APPLICATNS, PROD MAY
RELS VAPS THAT MAY PRODUCE
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >212F,>100C
Vapor Density: HVR/AIR
Spec Gravity: 0.98 (H*2O = 1)
Evaporation Rate & Reference: SLOWER THAN ETHER
Solubility in Water: INSOLUBLE
Appearance and Odor: BLACK LIQUID; SOLVENT ODOR
Percent Volatiles by Volume: 85.8
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HIGH TEMPERATURES. SOURCES OF IGNITION.
Materials To Avoid: STRONG OXIDIZERS, ACIDS, BASES, WATER.
Hazardous Decomposition Products: CARBON DIOXIDE, CARBON MONOXIDE, CHLORINE,
HYDROGEN CHLORIDE. PHOSGENE. LEAD FUME.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: CHEMLOK 253X
Cage: DO802
Assigned IND: Y
Company Name: LORD CORP
Street: 2000 W GRANDVIEW BLVD
PO Box: 10038
Zipcode: 16514
Label Required IND: Y
Date Of Label Review: 11/06/1997
Status Code: C
Label Date: 11/06/1997
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: Slight
Hazard And Precautions: FLAMMABLE. AVOID WATER. ACUTE: EYES CONTACT: MAY CAUSE
EYE IRRITATION. SKIN: MAY CAUSE SKIN IRRITATION. MAY CAUSE DERMATITIS. INHAL:
POSSIBLE IRRITATION OF THE RESP SYS CAN OCCUR CAUSING A VARIETY OF SYMPTOMS
SUCH AS DRYNESS OF THE THROAT,TIGHTNESS OF THE CHEST, AND SHORTNESS OF
BREATH. MAY CAUSE CNS DEPRESSION. INGEST: HARMFUL. CHRONIC: CONTAINS MATERIAL
WHICH APPEARS ON THE NAVY OCCUPATIONAL CHE MICAL REPRODUCTIVE HAZARD LIST (FP
N). LIVER/KIDNEY DAMAGE. CNS DAMAGE. DERMATITIS. TARGET ORGANS: NERVOUS, GI,
BLOOD. SYSTEMS.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ASTRO GEM/LEAD FREE GLAZES,FIRED ANTIQUE,UNDERGLAZES,619-151
CAGE:EO367
CAGE:EO367
CAGE:26290
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST;9596
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY
AND GASTROINTESTINAL TRACTS. ACUTE- EYE CONTACT MAY CAUSE
IRRITATION. PROLONGED SKIN CONTACT MAY CAUSE IRRITATION. INHALATION
OF DUSTS/MISTS MAY CAUSE LUNG INJURY . HARMFUL IF INGESTED.
CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:CONTAINS CRYSTALLINE SILICA.
Effects of Overexposure:IRRITATION, NAUSEA, VOMITING, TEARING, SHORTNES
OF BREATH
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING EYE
DISORDERS OR IMPAIRED RESPIRATORY FUNCTION MAY BE MORE SUSCEPTIBLE
TO THE EFFECTS OF THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:CALL PHYSICIAN IF SYMPTOMS PERSIST. EYE:IMMEDIATELY FLUSH
WITH WATER FOR 15 MINUTES. HOLD EYELIDS OPEN. SKIN:WASH WITH SOAP &
WATER. INHALED:MOVE TO FRESH AIR. PROVIDE CPR/OXYGEN IF NEEDED.
ORAL:CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NOT RELEVANT
Upper Limits:NOT RELEVANT
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS, IF NEEDED.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. VENTILATE AREA.
ABSORB ON SAND, VERMICULITE OR SIMILAR MATERIAL. SWEEP UP AND PLACE
IN AN APPROPRIATE CONTAINER FOR DISPOSAL.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
KEEP OUT OF REACH OF CHILDREN.
Other Precautions:DO NOT GET IN EYES, ON SKIN/ON CLOTHING. AVOID
INHALATION OF DUST/MIST. FOR INDUSTRIAL AND INSTITUTIONAL USE ONLY.
READ AND FOLLOW LABEL DIRECTIONS AND PRECAUTIONS. WASH AFTER
HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED. IF AIRBORNE CONCENTRATION
IS HIGH, WEAR A NIOSH-APPROVED DUST OR FUME RESPIRATOR.
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP MIST OR
DUST LEVELS AS LOW AS POSSIBLE, WHILE SPRAYING.
Other Protective Equipment:EYEBATH, WASHING FACILITY
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH BEFORE EATING OR DRINKING.
Supplemental Safety and Health
ASTRO GEM GLAZES, FIRED ANTIQUES, LEAD FREE GLAZES, ONE STROKE COLORS,
UNDERGLAZES, CERAMIC GLAZE(S), MISCELLANEOUS, STONEWARE GLASES,
LUSTER ASTRO GEMS, SERIES 2000 GLAZES, STROKE AND COAT SERIES
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NOT RELEVANT
Melt/Freeze Pt:M.P/F.P Text:1000F,538C
Spec Gravity:1.4 - 1.6
Solubility in Water:INSOLUBLE
Appearance and Odor:COLOR VARIABLE, AQUEOUS SLURRY - PRACTICALLY
ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN TRASH. OBSERVE LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:METHYL ALCOHOL 14280, A412P-4
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:METHANOL; (METHYL ALCOHOL) (SARA 313) (CERCLA).
LD50:(ORAL,RAT) 5628 MG/KG.
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: >99%
OSHA PEL:200 PPM, S
ACGIH TLV:200 PPM;250 STEL, S
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SUPDAT:INCOMPAT W/SPECIFIC CHEMS INCL:ACETYL BROMIDE, ALKYL
ALUMINUM SALTS, BERYLLIUM DIHYDRIDE, CARBON (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2:TETRACHLORIDE + METALS, CHLOROFORM + HEAT, CHLOROFORM
+ SODIUM HYDROXIDE, CYANURIC CHLORIDE, DIETHYL ZINC, (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:NITRIC ACID & POTASSIUM TERTBUTOXIDE. PLEASE REFER TO
NFPA FIRE PROTECTION GUIDE FOR ALL SPECIFICS.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP:CHRONIC:PRLNG/RPTD SKIN CONT MAY CAUSE
DERM. CHRONIC INHAL & INGEST MAY CAUSE EFTS SIMILAR TO (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:THOSE OF ACUTE INHAL & INGEST. TARGET ORGS:KIDNEYS,
CNS, LIVER, EYES. TOX INFO:EFTS ON NEWBORN:BEHAVIORAL; (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:EMBRYO/FETUS:FETOTOXICITY; SPECIFIC DEVEL
ABNORMS:CVS, MUSCULOSKELETAL, UROGENITAL; PATERNAL EFTS: (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:SPERMATOGENESIS; DNA DAMAGE; DNA INHIBITOR.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:TSP OF SYRUP OF IPECAC. INHAL:GET MED AID
IMMED. REMOVE FROM EXPOS TO FRESH AIR IMMED. IF NOT (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:BRTHG, GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE OXYG.
NOTES TO MD:EFTS MAY BE DELAYED. ETHANOL MAY INHIBIT (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:METABOLISM. ANTIDOTE:NO SPECIFIC ANTIDOTE EXISTS.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:STORAGE AREA. HARMFUL IF INHALED. POISON-CANNOT
BE MADE NON-POISONOUS. KEEP OUT OF REACH OF CHILDREN.(ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:IN CASE OF ACCIDENT/IF YOU FEEL UNWELL, SEEK MED
ADVICE IMMED (SHOW LBL WHERE POSS). KEEP CNTNR TIGHTLY CLOSED.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE:CAUSES MOD IRRIT. VAPS MAY
CAUSE IRRIT. MAY CAUSE PAINFUL SENSIT TO LIGHT. SKIN:MAY CAUSE
IRRIT. MAY BE ABSORBED IN HARMFUL AMTS. INGEST:MAY CAUSE IRRIT OF
DIGEST TRACT. MAY CAUSE CNS DEPRES S, CHARACT BY EXCITEMENT,
FOLLOWED BY HDCH, DIZZ, DROW & NAUS. ADVANCED STAGES MAY CAUSE
COLLAPSE, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:UNCON, COMA & POSS DEATH DUE TO RESP
FAILURE. MAY CAUSE KIDNEY FAILURE. INHAL:MAY CAUSE RESP TRACT
IRRIT. MAY CAUSE LIVER & KIDNEY DMG. MAY CAUSE ADVERSE CNS EFTS
INCL HDCH, CONVLS & POSS DEA TH. MAY CAUSE VISUAL IMPAIRMENT & POSS
PERM BLINDNESS. MAY CAUSE EFTS SIMILAR TO THOSE DESCRIBED FOR
INGEST. (ING 5)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/PLENTY OF WATER FOR AT LST 15 MINS, OCCAS
LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. DO NOT ALLOW VICTIM
TO RUB/KEEP EYES CLSD. SKIN:FLUSH W/PLENTY OF SOAP & WATER FOR AT
LST 15 MINS WHILE REMOVING CONTAM CLTHG & SHOES. GET MED AID IF
IRRIT DEVELS/PERSISTS. INGEST:IF VICTIM IS CONSCIOUS & ALERT, GIVE
2-4 CUPFULS OF MILK/WATER. GET MED AID IMMED. INDUCE VOMIT BY
GIVING 1 (ING 9)
===================== Fire Fighting Measures =====================
Flash Point:53.6F,12.0C
Lower Limits:6%
Upper Limits:31%
Extinguishing Media:FOR SMALL FIRES, USE DRY CHEMICAL, CARBON DIOXIDE,
WATER SPRAY OR ALCOHOL-RESISTANT FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . USE WATER TO COOL FIRE-EXPOSED CONTAINERS. WATER MAY BE
INEFFECTIVE.
Unusual Fire/Explosion Hazard:CNTNRS CAN BUILD UP PRESS IF EXPOS TO
HEAT &/OR FIRE. VAPS CAN TRAVEL TO SOURCE OF IGNIT & FLASH BACK.
DURING FIRE, IRRIT & HIGHLY TOX GASES MAY BE (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PPE AS INDICATED IN EXPOS CONTROLS,
PERSONAL PROT SECTION. SCOOP UP W/NONSPARKING TOOL, THEN PLACE INTO
SUITABLE CNTNR FOR DISP. USE WATER SPRAY TO DISPERSE GAS/VAP.
REMOVE ALL SOURCES OF I GNIT. ABSORB SPILL USING ABSORB, NON- (SUPP
DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE W/ADEQUATE VENT. EMPTY CONTAINERS
RETAIN PRODUCT RESIDUE (LIQUID &/OR VAPOR) & CAN BE DANGEROUS. DO
NOT GET ON SKIN/IN EYES. DO NOT INGEST/INHALE.
Other Precautions:DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL,
GRIND/EXPOSE EMPTY CNTNRS TO HEAT, SPKS/OPEN FLAMES. KEEP AWAY FROM
SOURCES OF IGNIT-NO SMOKING. STORE IN COOL, DRY, WELL-VENTED AREA
AWAY FROM INCO MPAT SUBSTANCES. STORE IN FLAMMS(ING 12)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW OSHA RESPIRATOR REGULATIONS FOUND IN 29
CFR 1910.134. ALWAYS USE A NIOSH APPROVED RESPIRATOR WHEN
NECESSARY.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
AIRBORNE CONCENTRATIONS BELOW PELS.
Other Protective Equipment:ANSI APPROVED EYE WASH FOUNTAIN & DELUGE
SHOWER . WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN
CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING & WASH BEFORE REUSE.
Supplemental Safety and Health
EXPLO HAZ:GENERATED BY THERMAL DECOMP/COMBUST. FLAMM LIQ. CAN RELS VAPS
THAT FORM EXPLO MIXTS AT TEMPS ABOVE FLASHPOINT. SPILL PROC:COMBUST
MATL SUCH AS EARTH, SAND/VERMICULITE. MATLS TO AVOID:SODIUM
HYPOCHLORITE), ACTIVE METALS (SUCH AS POTASSIUM & MAGNESIUM).
SUBSTANCE IS ALSO (ING 2)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:148F,65C
Melt/Freeze Pt:M.P/F.P Text:-144F,-98C
Vapor Pres:96
Vapor Density:1.1
Spec Gravity:0.7910
Evaporation Rate & Reference:5.2 (ETHER=1)
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID; SLIGHT ALCOHOL-LIKE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDANTS (SUCH AS BARIUM PERCHLORATE, BROMINE, CHLORINE, HYDROGEN
PEROXIDE, LEAD PERCHLORATE, PERCHLORIC ACID, (SUPDAT)
Stability Condition to Avoid:HIGH TEMPERATURES, INCOMPATIBLE MATERIALS,
IGNITION SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
FORMALDEHYDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT W/FEDERAL,
STATE & LOCAL REGULATIONS. RCRA WASTE NUMBER:U154 (IGNITABLE
WASTE). THIS MATERIAL IS BANNED FROM LAND DISPOSAL ACCORDING TO
RCRA.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:S00307 HEAVY DUTY PAINTABLE, MOLD RELEASE (SUP DAT)
CAGE:DO642
CAGE:DO642
CAGE:09800
============= Composition/Information on Ingredients =============
Ingred Name:HEPTANE VP: 50.0
CAS:142-82-5
RTECS #:MI7700000
Fraction by Wt: 10%
OSHA PEL:500 PPM
ACGIH TLV:400 PPM/500STEL
Ingred Name:ETHANE, 1,1-DIFLUORO-; (1,1-DIFLUOROETHANE) VP: 760.0
CAS:75-37-6
RTECS #:KI1410000
Fraction by Wt: 57%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:METHYL ETHER; (DIMETHYL ETHER) VP: 760.0
CAS:115-10-6
RTECS #:PM4780000
Fraction by Wt: 31%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOC AS PERCENT BY WT PER BAAQMD RULE 49: 40.6; VOC TOTAL:
2.66 LBS/GAL
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:OTHER PREC: ELEC TOOLS & APPLIANCES, & ANY OTHER SOURCES OF
IGNIT. CONSULT NFPA CODE. USE APPRVD BONDING & (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: GROUNDING PROC. CONTENTS UNDER PRESS. DO NOT
PUNCTURE, INCIN/EXPOSE TO TEMP > 120F. HEAT FROM SUNLIGHT, (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: RADIATORS, STOVES, HOT WATER, & OTHER HEAT SOURCES
COULD CAUSE CONTR TO BURST. DO NOT TAKE INTERNALLY. (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: KEEP OUT OF REACH OF CHILDREN. INTENTIONAL MISUSE BY
DELIBERATELY CONC & INHALING CONTENTS CAN BE HARMFUL/FATAL.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRIT OF EYES, SKIN & RESP SYS.
MAY CAUSE NERV SYS DEPRESS. EXTREME OVEREXP MAY RSLT IN UNCON &
POSS DEATH. SIGNS & SYMPS OF OVEREXP: EXCESS EXPOS TO VAPS/SPRAY
MISTS MAY CAUSE HDCH, DIZZ, NAUS & LOSS OF COORD. EYE/EXCESS SKIN
EXPOSMAY CAUSE REDNESS & ITCH/BURNING SENSATION. CHRONIC: PRLNG
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: OVEREXP TO SOLV INGS MAY CAUSE
ADVERSE EFTS TO LIVER & URINARY SYS. RPTS HAVE ASSOC RPTD & PRLNG
OVEREXP TO SOLVENTS W/PERM BRAIN & NERV SYS DMG. WARNING! THESE
PRODS CONTAIN CHEMS KNOWN TO STATE OF CALIFORNIA TO CAUSE CANCER &
BIRTH DEFECTS & OTHER REPRO HARM (CALIFORNIA PROPOSITION 65).
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP
WARM AND QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP AND
WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE. EYES:
FLUSH WI TH LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. GET
MEDICAL ATTENTION. INGESTION: NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. GIVE SEVERAL GLASSES OF WATER. SEEK MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:<0F,<-18C
Lower Limits:1.1%
Upper Limits:27.0%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER SPRAY MAY BE INEFFECTIVE. IF WATER USED, FOG NOZZ PREF. WATER
MAY BE USED TO COOL CLSD CONTRS (SUP DAT)
Unusual Fire/Explosion Hazard:CLSD CONTRS MAY EXPLODE (DUE TO BUILD-UP
OF PRESS) WHEN EXPOSED TO EXTREME HEAT. ISOLATE FROM HEAT, ELEC
EQUIP, SPKS & OPEN FLAME. APPLICATION TO HOT (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE ONLY W/ADEQ VENT. AVOID BRTHG VAP
& SPRAY MIST. AVOID CONT W/SKIN & EYES. CONTENTS ARE FLAMM. KEEP
AWAY FROM HEAT, SPKS, & OPEN FLAME.
Other Precautions:CONTENTS ARE FLAMM. KEEP AWAY FROM HEAT, SPKS & OPEN
FLAME. VAPS WILL ACCUM READILY & MAY IGNITE EXPLO. DURING USE &
UNTIL ALL VAPS ARE GONE: KEEP AREA VENTD; DO NOT SMOKE; EXTING ALL
FLAMES, PILOT LI GHTS & HEATERS; TURN OFF STOVES, (ING 5)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, WEAR A PROPERLY FITTED ORGANIC
VAPOR/CARTRIDGE RESPIRATOR APPROVED BY NIOSH FOR PROTECTION AGAINST
MATERIALS LISTED IN INGREDIENTS SECTION.
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPTABLE IF EXPOS IS MAINTAINED
< APPLIC LIMS. REFER TO OSHA STDS 1910.94, 1910. (SUP DAT)
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
TRADE NAME/PART #: AGENTS & MOLD MAINTENANCE-2. FIRE FIGHT PROC: TO
PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN EXPOSED TO EXTREME
HEAT. EXPLO HAZ: SURFS REQUIRES SPECIAL PREC. DURING EMER CNDTNS
OVEREXP TO DECOMP PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE IMMED
APPARENT. OBTAIN MED ATTN. VENT: 107, 1910.108.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>0F,>-18C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:0.77-0.80
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THESE PRODS MAY BE HAZ AS DEFINED
UNDER RCRA 40 CFR 261. WASTE MUST BE TESTED FOR IGNITABILITY TO
DETERMINE APPLIC EPA HAZ WASTE NUMBERS. DO NOT INCIN. DEPRESSURIZE
CONTR. DISP OF I/A/W FED , STATE & LOC REGS REGARDING POLLUTION.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:2107 HI-HEAT RED, KRYLON HIGH HEAT RESISTANT PAINTS
CAGE:IO479
CAGE:IO479
CAGE:09800
============= Composition/Information on Ingredients =============
Ingred Name:PROPANE. VP:700.
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 18%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (PETROLEUM
DISTILLATES). VP:2.
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 2%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:TOLUENE (SARA 313) (CERCLA). VP:22.
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 30%
OSHA PEL:200 PPM
ACGIH TLV:50 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE (SARA 313) (CERCLA). VP:180.
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 37%
OSHA PEL:1000 PPM
ACGIH TLV:750 PPM;1000 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CADMIUM SULFIDE (INVALID MFR CAS NO:106-23-6)
CAS:1306-23-6
RTECS #:EV3150000
Fraction by Wt: 4%
OSHA PEL:0.2 MG/M3 (CD)
ACGIH TLV:0.05 MG/M3 (CD)
Ingred Name:CADMIUM SELENIDE
CAS:1306-24-7
Fraction by Wt: 3%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BARIUM SULFATE
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: 7%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:SUPP DATA:CONC & INHAL CONTENTS CAN BE HARMFUL/FATAL. CAL
PROP 65:CONTAINS CHEM(S) KNOWN TO THE STATE OF (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 9:CALIFORNIA TO CAUSE CANCER, BIRTH DEFECTS/OTHER REPRO
HARM. NOTE:TOLUENE APPEARS ON NAVY LIST OF OCCUP (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:CHEM REPRO HAZS. SEEK CONSULTATION FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:HANDLING & EXPOSURE INFORMATION .
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:PROCS. CONTENTS UNDER PRESS. DO NOT PUNCTURE,
INCIN/EXPOSE TO TEMPS >120F. HEAT FROM SUNLIGHT, (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:RADIATORS, STOVES, HOT WATER & OTHER HEAT SOURCES
COULD CAUSE CNTNR TO BURST. DO NOT TAKE INTERNALLY. (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:KEEP OUT OF REACH OF CHILDREN. USE ONLY W/ADEQ VENT.
AVOID BRTHG VAP & SPRAY MIST. AVOID CONT W/SKIN & (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:EYES. THESE COATINGS MAY CONTAIN MATLS CLASSIFIED AS
NUISANCE PARTICULATES WHICH MAY BE PRESENT AT HAZ (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:LEVELS ONLY DURING SANDING/ABRADING OF DRIED FILM.
IF NO SPECIFIC DUSTS ARE LISTED, APPLIC LIMS FOR (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:NUISANCE DUSTS ARE ACGIH TLV 10 MG/M3 (TDUST), OSHA
PEL 15 MG/M3 (TDUST), 5 MG/M3 (RESPIRABLE FRACTION). (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:ADDITION OF REDUCERS/OTHER ADDITIVES TO THIS PRODUCT
MAY SUBSTANTIALLY ALTER COMPOSITION & HAZARDS OF PRODUCT.
RTECS #:9999999ZZ
Ingred Name:EXPLAN OF CARCIN:BE CARCINOGEN. HUMAN:LUNG & PROSTATE
CANCER, RENAL SYSTEM EFFECTS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EXPOS MAY BE BY INHAL &/OR SKIN/EYE
CONT, DEPENDING ON CNDTNS OF USE, MIN EXPOS, FOLLOW RECS FOR PROPER
USE, VENT & PPE. ACUTE:IRRIT OF EYES, SKIN & RESP SYS. MAY CAUSE
NERV SYS DEPRESS. EXTREME OVERE XP MAY RSLT IN UNCON & POSS DEATH.
HDCH, DIZZ, NAUS & LOSS OF COORD ARE INDICATIONS OF EXCESSIVE EXPOS
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:CADMIUM SULFIDE:IARC MONOGRAPHS, SUPP,
VOL 7, PG 139, 1987:GRP 2A. NTP 7TH ANNUAL RPT ON CARCINS,
1994:ANTIC TO (ING 20)
Effects of Overexposure:HLTH HAZ:TO VAPS/SPRAY MISTS. REDNESS &
ITCH/BURNING SENSATION MAY INDICATE EYE/EXCESSIVE SKIN EXPOS.
CHRONIC:PRLNG OVEREXP TO SOLV INGS MAY CAUSE ADVERSE EFTS TO LIVER,
URINARY, BLOOD FORMING, CVS & REPRO SYS. RPTS HAVE ASSOC RPTD &
PRLNGOVEREXP TO SOLVS W/PERM BRAIN & NERV SYS DMG. INTENTIONAL
MISUSE BY (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM &
QUIET. SKIN:WASH AFFECTED AREA THOROUGHLY W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING & LAUNDER BEFORE RE-USE. EYES:FLUSH W/LARGE
AMOUNTS OFWATER FOR AT LEAST 15 MINUTES. GET MEDICAL ATTENTION.
INGEST:SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:<0F,<-18C
Lower Limits:1%
Upper Limits:16.5%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER SPRAY MAY BE INEFT. IF WATER IS USED, FOG NOZZ ARE PREF.
WATER MAY BE USED TO COOL CLSD CNTNRS TO (SUPDAT)
Unusual Fire/Explosion Hazard:EXTREMELY FLAMM. ISOLATE FROM HEAT, ELEC
EQUIP, SPKS & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN EXPOS TO
EXTREME HEAT. APPLICATION TO HOT SURFS REQS (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE &
REMOVE W/INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NFPA CODE 10B-LEVEL 3 AEROSOL.
CONTENTS ARE EXTREMELY FLAMM. KEEP AWAY FROM HEAT, SPKS & OPEN
FLAME. VAPS WILL ACCUM READILY & MAY IGNITE EXPLOSIVELY.
Other Precautions:DURING USE & UNTIL ALL VAPS ARE GONE:KEEP AREA
VENTED; DO NOT SMOKE; EXTING ALL FLAMES, PILOT LIGHTS & HEATERS;
TURN OFF STOVES, ELEC TOOLS & APPLIANCES & ANY OTHER SOURCES OF
IGNIT. CONSULT NFPA CODE . USE APPRVD BONDING & GROUNDING(ING 14)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIMS BY VENT, WEAR PROPERLY FITTED NIOSH APPRVD ORG
VAP/PARTICULATE RESP FOR PROT AGAINST INGS. WHEN SANDING/ABRADING
DRIED FILM, WEAR NIOSH APPRVD DUST/MIST RESP FOR PROT
AGAINST(SUPDAT)
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPT IF EXPOS TO INGS IS
MAINTAINED BELOW APPLIC EXPOS LIMS. REFER TO OSHA STDS (SUPP DATA)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC:PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN EXPOS
TO EXTREME HEAT. RESP PROT:NON-VOLATILE INGS. VENT:1910.94,
1910.107, 1910.108. EXPLO HAZ:SPECIAL PRECS. DURING EMER CNDTNS
OVEREX P TO DECOMP PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE IMMED
APPARENT. OBTAIN MED ATTN. EFTS OF OVEREXP:DELIB (ING 9)
================== Physical/Chemical Properties ==================
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Volatile Org Content %:88
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THIS PROD MAY BE HAZ AS DEFINED UNDER
THE RCRA (40 CFR 261). WASTE MUST BE TESTED FOR IGNITABILITY TO
DETERMINE APPLIC EPA HAZ WASTE NUMBERS. DO NOT INCIN. DEPRESSURIZE
CNTNR. DISP OF I/A/W FED, STATE & LOC REGS REGARDING POLLUTION.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:POLYESTER RESIN DION FR 6692-T, 75362101
Preparer's Name:OCCUP HLTH/PROD SFTY DEPT
CAGE:00297
CAGE:00297
============= Composition/Information on Ingredients =============
Ingred Name:METHYLENE CHLORIDE(SARA III)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: < 0.5%
OSHA PEL:500 PPM/C,1000; Z2
ACGIH TLV:50 PPM, A2; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:RESP: FILTER UNITS OK.
RTECS #:9999999ZZ
Ingred Name:VENT: LIMITS & AREAS BELOW FLAMMABLE VAPOR CONCENTRATIONS.
LOCAL EXHST MAY BE NEC FOR USE IN ENCLOSED/CONFINED SPACES.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: RELEASED INTO THE ENVIRONMENT MUST BE REPORTED
TO THE NATIONAL RESPONSE CNTR(1-800-424-8802). IF THIS(ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: PRODUCT IS SPILLED OR LEAKED, THE REPORTABLE
QUANTITY IS 100 LBS.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: EFTS FROM OVEREXP. TREATMENT SHOULD BE
DIRECTED AT THE CONTROL OF SYMPTOMS AND THE CLINICAL CONDITION.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP: EXCEPT FOR LIFE-SUSTAINING USES IN HUMANS
ACUTELY OR CHRONICALLY EXPOSED TO CHLOROCARBONS .
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: HEAT AND/OR UV RADIATION MAY CAUSE THE
FORMATION OF HCL AND/OR PHOSGENE .
RTECS #:9999999ZZ
Ingred Name:OTHER PROT EQUIP: SAFETY SHOWER AND EYE WASH FOUNTAINS
SHOULD BE PRESENT.
RTECS #:9999999ZZ
Ingred Name:EPICHLOROHYDRIN (SARA III)
CAS:106-89-8
RTECS #:TX4900000
Fraction by Wt: < 0.5%
OSHA PEL:S, 5 PPM
ACGIH TLV:S, 2 PPM; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:STYRENE, MONOMER (SARA III)
CAS:100-42-5
RTECS #:WL3675000
Fraction by Wt: < 30%
OSHA PEL:100 PPM
ACGIH TLV:S,50PPM/100STEL;9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYE:VAPS MAY CAUSE IRRIT, TEARING,
BLURRED VISION. DIRECT CNTCT W/RESIN MAY PRODUCE CORNEAL DAMAGE.
SKIN:RPTD &/OR PRLNGD CNTCT CAN CAUSE IRRIT. ABSORPTION OF LIQUID
THRU SKIN MAY PRODUCE DAMAGE TO IN TERNAL ORGANS. INHAL:HIGH CONC
OF VAPS CAN CAUSE IRRIT OF RESP TRACT INCLUDING NOSE & THROAT,
HDCHES, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:METHYLENE CHLORIDE:GROUP 2B(IARC), GROUP
2(NTP), STYRENE:GROUP 2B(IARC). EPICHLOROHYDRIN:GROUP 2A(IARC),
GROUP 2(NTP)
Effects of Overexposure:HLTH HAZ: DIZZ, NAUSEA, WEAKNESS,
COLLAPSE/COMA/DEATH. LIVER & KIDNEY DAMAGE HAVE BEEN REPORTED AT
HIGH DOES IN ANIMALS STUDIES. CHLOROCARBON MATLS HAVE PRODUCED
SENSIT OF THE MYOCARDIUM TO EPINEPHRIN E IN LAB ANIMALS & COULD
HAVE A SIMILAREFT IN HUMANS. ADRENOMIMETICS (E.G. EPINEPHRINE) MAY
BE CONTRAINDICATED (ING 9)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE: IMMED FLUSH W/LRG AMNTS OF WATER FOR AT LEAST 15 MIN.
SKIN: REMOVE CONTAMINATED CLOTHING. WASH THOROUGHLY WITH SOAP AND
WATER. IF IRRIT PERSISTS, SEEK MEDICAL AID. WIPE MATL FROM SKIN.
INHAL: REM OVE FROM EXPOS. IF BRTHG HAS STOPPED/ISDIFFICULT, GIVE
ARTF RESP/O*2 AS INDICATED. SEEK MED AID. INGEST: DO NO INDUCE
VOMIT. IMMED SEEK MED. NOTE TO MD: THERE IS NOT SPECIFIC ANTIDOTE
FOR (ING 8)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:84.2F,29.0C
Lower Limits:1.1 %
Upper Limits:6.1 %
Extinguishing Media:USE CARBON DIOXIDE, DRY CHEMICAL OR FOAM. WATER MAY
BE INEFFECTIVE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD PRESS DEMAND SCBA &
FULL PROT EQUIP. USE H*2O TO COOL FIRE-EXPOS CNTNR/STRUCTURE/PROT
PERSONNEL. LRG FIRE: FIRE FIGHT (SUPP DATA)
Unusual Fire/Explosion Hazard:VAPS FORM FLAM/EXPLO MIX IN AIR.VAP
HEAVY, MAY TRAVEL TO IGNIT SOURCE-FLASH.IF POLYM OCCURS, EXPLOS
RUPTURING MAY OCCUR.STYRENE VAPS ARE UNINHIBITED.(SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:STOP LEAK IF NO RISK INVOLVED. STAY UPWIND.
SMALL SPILLS: TAKE UP WITH SAND OR OTHER NONCOMBUSTIBLE ABSORBENT
MATERIAL. FLUSH AREA WITH WATER. DIKE LARGE SPILLS FOR LATER DISP.
CNTN RUNOFF FROM FIRE C ONTROL AND DILUTION WATER. THIS PROD
(INGRED 6)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PRLNG/RPTD BRTHG OF
VAPS/MISTS/FUMES. AVOID PRLNG/RPTD CNTCT W/SKIN/EYES. HNDL/USE
I/A/W OSHA 29CFR1910.106/LOC CODES. DO NOT WEAR CONTAM CLTHG.
Other Precautions:DISCARD CONTAM FOOTWEAR. STORE IN AREAS/BLDGS
DESIGNED TO COMPLY W/OSHA 1910.106. KEEP IN CLSD/LABELED CNTNR
WITHIN A COOL, DRY-VENT. NO SMOKING IN AREA OF USE. DO NOT USE IN
THE GEN VICIN OF ARC WELD ING, OPEN FLAMES/HOT SURF. (ING 10)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER NORMAL USE CNDTNS. IF VENT
DOES NOT MAINTAIN INHAL EXPOS BELOW TLV(PEL), USE NIOSH/MSHA APPRVD
UNITS AS PER CURRENT 29 CFR1910.134 AND MFR "INSTRUCTIONS" AND
"WARNINGS". IF WITHIN O SHA PROT FACTOR, AIR PURIFYING (ING 4)
Ventilation:NOT NORMALLY REQUIRED. PROVIDE SUFF GEN/LOC EXHST VENT IN
PATTERN/VOL TO CONTROL INHAL EXPOS BELOW CURRENT EXPOS (ING 5)
Other Protective Equipment:WORK CLTHG & SAFETY FOOTWEAR. DEPENDING ON
WORK CNDTNS, I.E. CNTCT POTENTIAL, WEAR RESISTANT PROT GARMENTS.
(ING 11)
Work Hygienic Practices:OBSERVE GOOD HYGIENE PRACTICES AND RECOMMENDED
PROCEDURES. SHOWER AND CLOTHING CHANGE REC AT THE END OF EACH
SHIFT.
Supplemental Safety and Health
FIRE FIGHT PROC:BEST @ DISTANCE/PROT LOCATION. EXPLO HAZ:POLYM MAY FORM
IN STOR TANK VENTS/FLAME ARRESTORS RESULTING IN VENT STOPPAGE/EXPLO
RUPTURING. VAPS FORM EXPLO MIXT IN AIR AT ELEVATED TEMPS. FI RE CAN
CAUSE FORM OF HCL/SMALL AMTS OF CL*2 & PHOSGENE. THERMAL DECOMP
PROD MAY INCLUDE HCL & PHOSGENE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:231F,146C
Melt/Freeze Pt:M.P/F.P Text:LIQUID
Vapor Pres:4.4 @20C
Spec Gravity:1-1.4
pH:ACIDIC
Evaporation Rate & Reference:SLOWER (ETHER=1)
Solubility in Water:SLIGHT
Appearance and Odor:VISCOUS LIQUID WITH A STYRENE ODOR.
Percent Volatiles by Volume:20-70
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, ACIDS, CAUSTIC, METALLIC HALIDES (SALTS).
Stability Condition to Avoid:HEAT, OXIDIZING AGENTS, FREE RADICAL
CATALYSTS, PEROXIDE.
Hazardous Decomposition Products:SMOKE, CARBON MONOXIDE, CARBON
DIOXIDE, HALOGENS AND HALOGEN BYPRODUCTS. HCL, PHOSGENE .
Conditions to Avoid Polymerization:HEAT, OXIDIZING AGENTS, FREE RADICAL
CATALYSTS, PEROXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGUALTIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:1501 GLOSSY WHITE, INDUSTRIAL MAINTENANCE & (SUPDAT)
CAGE:DO934
CAGE:DO934
CAGE:KRYLX
============= Composition/Information on Ingredients =============
Ingred Name:PROPANE (PROPELLANT). VP:760.
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 13%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT
Ingred Name:PROPANE, 2-METHYL-; (ISOBUTANE) (2-METHYLPROPANE
(PROPELLANT)). VP:760.
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BENZENE, ETHYL-; (ETHYLBENZENE) (SARA 313). VP:7.1.
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 2%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM;125 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE (SARA 313) (CERCLA). VP:5.9.
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 11%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM;150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BUTYL ALCOHOL; (1-BUTANOL)(SARA 313) (CERCLA). VP:5.5.
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 2%
OSHA PEL:100 PPM
ACGIH TLV:50 PPM, S, C
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETONE (SARA 313) (CERCLA). VP:180.
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 35%
OSHA PEL:1000 PPM
ACGIH TLV:750 PPM;1000 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE) (MEK) (SARA 313)
(CERCLA). VP:70.
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 4%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM;300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER;
(1-METHOXY-2-PROPANOL ACETATE). VP:1.8.
CAS:108-65-6
RTECS #:AI8925000
Fraction by Wt: 7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 7%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:VOLATILE ORGANIC COMPOUNDS (BAAQMD RULE 49): 81% BY WT.
RTECS #:9999999VO
Ingred Name:SUPP DATA:DECOMPOSITION PRODUCTS MAY CAUSE HEALTH HAZARD.
SYMPTOMS MAY NOT BE IMMED APPARENT. OBTAIN MEDICAL ATTENTION.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP:AT 250 MG/M3 DEVEL LUNG CANCER, HOWEVER,
SUCH EXPOS LEVELS ARE NOT ATTAINABLE IN WORKPLACE. RPTS(ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:HAVE ASSOC RPTD & PRLNG OVEREXP TO SOLVS W/PERM
BRAIN & NERV SYS DMG. INTENTIONAL MISUSE BY DELIB CONC & (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:INHAL CONTENTS CAN BE HARMFUL/FATAL. CAL PROP
65:THIS PROD CONTAINS CHEM KNOWN TO THE STATE OF CALIFORNIA(ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:TO CAUSE CANCER, BIRTH DEFECTS OR OTHER REPRODUCTIVE
HARM.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:PROCS. CONTENTS UNDER PRESS. DO NOT PUNCTURE,
INCIN/EXPOSE TO TEMP >120F. HEAT FROM SUNLIGHT, (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:RADIATORS, STOVES, HOT WATER & OTHER HEAT SOURCES
COULD CAUSE CNTNR TO BURST. DO NOT TAKE INTERNALLY. (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:KEEP OUT OF REACH OF CHILDREN. USE ONLY W/ADEQ VENT.
AVOID CONT W/SKIN & EYES. THIS COATING MAY CONTAIN (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:MATLS CLASSIFIED AS NUISANCE PARTICULATES WHICH MAY
BE PRESENT AT HAZ LEVELS ONLY DURING SANDING/ABRADING(ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19:OF DRIED FILM. IF NO SPECIFIC DUSTS ARE LISTED,
APPLIC LIMS FOR NUISANCE DUSTS ARE ACGIH TLV 10 MG/M3 (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20:TDUST; OSHA PEL 15 MG/M3 TDUST, 5 MG/M3 RESPIRABLE
FRACTION.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH:DEPRESSURIZE CONTAINER. DISPOSE OF I/A/W
FEDERAL, STATE & LOCAL REGULATIONS REGARDING POLLUTION.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPOS MAY BE BY INHAL &/OR SKIN/EYE
CONT, DEPENDING ON CNDTNS OF USE. TO MIN EXPOS, FOLLOW RECS FOR
PROPER USE, VENT & PPE. ACUTE:IRRIT OF EYES, SKIN & RESP SYS. MAY
CAUSE NERV SYS DEPRESS. EXTREME OV EREXP MAY RSLT IN UNCON & POSS
DEATH. HDCH, DIZZ, NAUS & LOSS OF COORD ARE INDICATIONS OF
EXCESSIVE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:EXPOS TO VAPS/SPRAY MIST. REDNESS &
ITCH/BURNING SENSATION MAY INDICATE EYE/EXCESSIVE SKIN EXPOS.
CHRONIC:PRLNG OVEREXP TO SOLV INGS MAY CAUSE ADVERSE EFTS TO LIVER,
URINARY, BLOOD-FORMING, C VS & REPRO SYS. METHYL ETHYL KETONE
MAYINCR NERV SYS EFTS OF OTHER SOLVS. RATS EXPOS TO TITANIUM
DIOXIDE DUST (ING 12)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM &
QUIET. SKIN:WASH AFFECTED AREA THROUGHLY W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING & LAUNDER BEFORE RE-USE. EYES:FLUSH W/LARGE
AMOUNTS OFWATER FOR AT LEAST 15 MINUTES. GET MEDICAL ATTENTION.
INGEST:GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:<0F,<-18C
Lower Limits:0.9%
Upper Limits:13.1%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER SPRAY MAY BE INEFT. IF WATER IS USED, FOG NOZZ ARE PREF.
WATER MAY BE USED TO COOL CLSD CNTNRS TO (SUPDAT)
Unusual Fire/Explosion Hazard:EXTREMELY FLAMM. ISOLATE FROM HEAT, ELEC
EQUIP, SPKS & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN EXPOS TO
EXTREME HEAT. APPLICATION TO HOT SURFS REQS (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE &
REMOVE W/INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DOL STOR CATEGORY-1A. KEEP AWAY FROM
HEAT, SPKS & OPEN FLAME. VAPS WILL ACCUM READILY & MAY IGNITE
EXPLOSIVELY. AVOID BRTHG VAP & SPRAY MIST.
Other Precautions:DURING USE & UNTIL ALL VAPS ARE GONE:KEEP AREA
VENTED; DO NOT SMOKE; EXTING ALL FLAMES, PILOT LIGHTS & HEATERS;
TURN OFF STOVES; ELEC TOOLS & APPLIANCES & ANY OTHER SOURCES OF
IGNIT. CONSULT NFPA CODE . USE APPRVD BONDING & GROUNDING(ING 16)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIMS BY VENT, WEAR PROPERLY FITTED NIOSH APPRVD ORG
VAP/PARTICULATE RESP FOR PROT AGAINST INGS. WHEN SANDING/ABRADING
DRIED FILM, WEAR NIOSH APPRVD DUST/MIST RESP FOR DUST WHICH
(SUPDAT)
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPT IF EXPOS TO INGS IS
MAINTAINED BELOW APPLIC EXPOS LIMS. REFER TO OSHA STDS (SUPP DATA)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:TOUCH UP SPRAY COLORS. FIRE FIGHT PROC:PVNT
PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN EXPOS TO EXTREME HEAT.
RESP PROT:MAY BE GENERATED FROM THIS PROD, UNDERLYING PAINT/ABRAS
IVE. VENT:1910.94, 1910.107, 1910.108. EXPLO HAZ:SPECIAL PRECS.
DURING EMER CNDTNS OVEREXP TO (ING 11)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:<302F,<150C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF METALS IN INGREDIENTS SECTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THIS PROD MAY BE HAZ AS DEFINED UNDER
RCRA (40 CFR 261). WASTE MUST BE TESTED FOR IGNITABILITY TO
DETERMINE APPLIC EPA HAZ WASTE #'S. WASTE FROM PRODS CNTNG METHYL
ETHYL KETONE MAY REQ TEST ING FOR EXTRACTABILITY. DO NOT INCIN.
(ING 22)
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:GC FORMULA 202-KC
CAGE:56733
CAGE:56733
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 15-20%
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:SKIN:MAY IRRITATE OR BURN.
EYE:WILL BURN OR SEVERELY IRRITATE. INGEST:MAY IRRITATE OR BURN
MOUTH, THROAT, AND STOMACH. MAY CAUSE SERIOUS DAMAGE TO MOUTH,
THROAT, AND STOMACH. CHRONIC:REPEATED OR PROLONGED CONTACT MAY
CAUSE DERMATITIS(SKIN REDNESS, DRYNESS, SCALING, ETC.).
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE TO FRESH AIR. SUPPORT BRTHG (GIVE O*2/ARTF RESP) .
SKIN:WASH W/WATER, CALL MD IF PAIN, IRRIT OR OTHER PROBLEMS
PERSIST. EYE:FLOOD W/LUKEWARM WATER (NOT HOT) FROM LRG GLASS HELD
2-3" F ROM EYE, OR USE EYE WASH FOUNTAIN. DO THIS FOR 15 MINS. HAVE
PATIENT BLINK AS MUCH AS POSS WHILE FLOODING EYE. DO NOT FORCE
EYELID OPEN. CALL MD. INGEST:GIVE WATER/MILK. DO NOT INDUCE VOMIT.
CALL MD.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:ANY MEDIA MAY BE USED.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NO SPECIAL HAZARDS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE CLOTHNG. SMALL SPILLS OF ONE
GALLON OR LESS MAY BE FLUSHED TO DRAIN WITH LARGE AMOUNTS OF WATER.
FOR LARGER SPILLS, CONTAIN WITH ABSORBENT MATERIAL. PLACE IN
PLASTIC BAG.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER COVERED & SEALED WHEN
NOT IN USE. STORE IN A COOL, DRY AREA.
Other Precautions:DO NOT ADD WATER OR ANY OTHER MATERIAL TO DRUM OF
PRODUCT OR OTHERWISE CONTAMINATE IT. READ PRODUCT LABEL FOR FURTHER
INSTRUCTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPRIATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NORMAL ROOM VENTILATION.
Other Protective Equipment:PLASTIC OR RUBBER APRON. EYE WASH AND SAFETY
SHOWER IN WORK AREA.
Work Hygienic Practices:REMOVE CONTAM CLTHG & WASH BEFORE REUSE. IF
HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:210F,99C
Spec Gravity:1.1
pH:>13
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR VISCOUS LIQUID WITH NO ODOR
Percent Volatiles by Volume:80
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, METALS SUCH AS MAGNESIUM, ALUMINUM, ZINC, TIN, CHROMIUM,
BRASS AND BRONZE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN WASTE MANAGEMENT FACILITY OR IN
COMPLIANCE W/FEDERAL , STATE AND LOCAL REGULATIONS. IF SPILL IS NOT
CONTAMINATED YOU MAY BE ABLE TO DISPOSE OF MATERIALS WHERE NORMALLY
USED.
| 1 | eyes_protection_mandatory |
=======================================================
NIIN: 01-424-9920
Product ID: MA 554
Cage: JO736
Proprietary Ind: Y
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: JO736
Assigned Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: JO736
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: ADHESIVE
Specification Number: NA
Type/Grade/Class: NA
Unit of Issue: SH
UI Container Qty: 1
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYE: IRRITATION. SKIN: MAY CAUSE DERMATITIS & ALLERGIC
REACTION. INHAL: MAY CAUSE NOSE/THROAT IRRIT, HEADACHE, NAUSEA. INGEST: NOT
LIKELY.
Medical Cond Aggravated By Exposure: MAY CAUSE DERMATITIS AND ALLERGIC REACTION
IN SOME SENSITIVE PEOPLE.
First Aid: EYE: FLUSH W/WATER FOR 15 MINUTES, GET MED AID. SKIN: WASH W/PLENTY
OF WATER. GET MED AID IF IRRIT DEVELOPS. INHAL: REMOVE TO FRESH AIR. IF NOT
BREATHING, GIVE ARTIFICIAL RESP. IF BREATHING DIF, GIVE OXYGEN. CALL DR.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: PLACE IN SUITABLE CONTAINER FOR DISPOSAL.
Waste Disposal Methods: NOT DEFINED AS HAZARDOUS. INCINERATE/LANDFILL IN
ACCORDANCE W/FEDERAL, STATE AND LOCAL REGULATIONS.
Handling And Storage Precautions: USE ONLY IN WELL VENTED AREA. AVOID PROLONGED
SKIN CONTACT/BREATHING OF VAPOR. STORE AT 0F OR BELOW.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point Text: NA
Lower Limits: NA
Upper Limits: 8.6
Extinguishing Media: CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures: DONT ENTER CONFINED FIRE SPACE WITHOUT PROPER
EQUIPMENT INCLUDING NIOSH APPROVED SCBA.
Unusual Fire/Explosion Hazard: EXOTHERM MAY OCCUR WHEN LARGE MASSES ARE HEATED
ABOVE 200F.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT NORMALLY NEEDED. USE NIOSH APPROVED ORGANIC
RESPIRATOR FOR VAPORS FROM HEATED PRODUCT.
Ventilation: GENERAL VENT TO REMOVE VAPORS WHEN PRODUCT IS HEATED.
Other Protective Equipment: EYEWASH STATION.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: NONE
M.P/F.P Text: NA
Decomp Text: NA
Vapor Pres: NA
Vapor Density: NONVOL
Spec Gravity: 1.22809
PH: NA
Viscosity: >WATER
Evaporation Rate & Reference: NONVOL
Solubility in Water: NA
Appearance and Odor: BLACK SEMI-SOLID, EPOXY ODOR.
Percent Volatiles by Volume: 0.0
Corrosion Rate: NA
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: AVOID HEATING LARGE MASSES AS EXOTHERM MAY OCUR.
Materials To Avoid: STRONG ACIDS, BASES OR OXIDIZING AGENTS.
Hazardous Decomposition Products: CARBON DIOXIDE, CARBON MONOXIDE, AMMONIA,
OTHER TOXIC FUMES POSSIBLE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NONE
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 136116
Product ID: MA 554
Review Date: 06/23/1998
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: SH
Container QTY: 1
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: MA 554
Cage: JO736
Assigned IND: Y
Company Name: SOVEREIGN ENGINEERED ADHESIVES
Street: 123 WEST BARTGES ST
Zipcode: 44311
Label Required IND: Y
Date Of Label Review: 10/12/1999
Status Code: A
Origination Code: G
Hazard And Precautions: EYE: IRRITATION. SKIN: MAY CAUSE DERMATITIS &
ALLERGIC REACTION. INHAL: MAY CAUSE NOSE/THROAT IRRIT, HEADACHE, NAUSEA.
INGEST: NOT LIKELY.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MOBIL VELOCITE OIL NO 10
CAGE:6G112
CAGE:6G112
============= Composition/Information on Ingredients =============
Ingred Name:VOLATILE ORGANIC COMPOUNDS: 0.358 LBS/GAL
RTECS #:9999999VO
Ingred Name:ZINC
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: 0.03%
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ZINC DIAMYLDITHIOCARBAMATE *94-3*
CAS:15337-18-5
Fraction by Wt: 0.20%
Ingred Name:OIL PETROLEUM DISTILLATES, SOLVENT-DEWAXED HEAVY PARAFFINIC
CAS:64742-65-0
RTECS #:PY8038500
Fraction by Wt: >95%
Other REC Limits:5 MG/CUM
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): >2000 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. INHALATION:
RESPIRATORY IRRITATION. MATERIAL IF ASPIRATED INTO THE LUNGS MAY
CAUSE CHEMICAL PNEUMUNITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DIZZINESS, NAUSEA, UNCONSCIOUSNESS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH THOROUGHLY W/WATER. SKIN: WASH CONTACT AREAS
W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. IF BREATHING HAS
STOPPED, USE MOUTH TO MOUTH RESUSCITATION. INGESTION: IF GREATER
THAN 1/2 LIT ER INGESTED, IMMEDIATELY GIVE 1-2 GLASSES OF WATER.
DON'T INDUCE VOMITING/GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON. OBTAIN MEDICAL ATTENTION IN ALL CASES. (SEE SUPPLEMENTAL
DATA)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>360F
Extinguishing Media:CO2, FOAM, DRY CHEMICAL & WATER FOG.
Fire Fighting Procedures:USE SCBA. USE WATER TO KEEP CONTAINERS COOL.
WATER SPRAY MAY BE USED TO FLUSH SPILLS AWAY FROM EXPOSURE. PREVENT
RUNOFF FROM FIRE CONTROL/DILUTION.
Unusual Fire/Explosion Hazard:WATER/FOAM MAY CAUSE FROTHING.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB ON FIRE RETARDANT TREATED SAWDUST,
DIATOMACEOUS EARTH. SHOVEL UP & DISPOSE.
======================Handling and Storage ======================
Handling and Storage Precautions:USE IN WELL VENTILATED AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL REQUIREMENTS UNDER ORDINARY
CONDITIONS OF USE & W/ADEQUATE VENTILATION.
Ventilation:REQUIRED
Work Hygienic Practices:GOOD PERSONAL HYGIENE SHOULD ALWAYS BE
FOLLOWED.
Supplemental Safety and Health
NOTE TO PHYSICIANS: MATERIAL IF ASPIRATED INTO THE LUNGS MAY CAUSE
CHEMICAL PNEUMONITIS. TREAT APPROPRIATELY.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>600F
Vapor Pres:<0.1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT AMBER LIQUID W/MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:EXTREME HEAT.
Hazardous Decomposition Products:CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:1801 CHROME YELLOW, KRYLON INT./EXT. ENAMEL
Resp. Party Other MSDS Num.:KD-1601
CAGE:EO276
CAGE:EO276
Contract Num:MDA414-98-A-0047-0089
CAGE:26290
Contract Num:MDA414-00-P-2598
CAGE:0RKV4
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE
CAS:67-64-1
RTECS #:AL3150000
Minumum % Wt:30.
Maxumum % Wt:50.
OSHA PEL:2400 MG/M3;1000 PPM
ACGIH TLV:1780 MG/M3;750 PPM
ACGIH STEL:2380 MG/M3;1000 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:1-BUTANOL
CAS:71-36-3
RTECS #:EO1400000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:300 MG/M3;100 PPM
ACGIH STEL:C152 MG/M3;C50 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Minumum % Wt:10.
Maxumum % Wt:30.
OSHA PEL:1800 MG/M3;1000 PPM
Ingred Name:METHYL ETHYL KETONE
CAS:78-93-3
RTECS #:EL6475000
Minumum % Wt:5.
Maxumum % Wt:10.
OSHA PEL:590 MG/M3;200 PPM
ACGIH TLV:590 MG/M3;200 PPM
ACGIH STEL:885 MG/M3;300 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ISOBUTYL KETONE
CAS:108-10-1
RTECS #:SA9275000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:410 MG/M3;100 PPM
ACGIH TLV:205 MG/M3;50 PPM
ACGIH STEL:307 MG/M3;75 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-PROPANOL, 1-METHOXY-, ACETATE
CAS:108-65-6
RTECS #:AI8925000
Minumum % Wt:5.
Maxumum % Wt:10.
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:SEE TABLE Z-2
ACGIH TLV:188 MG/M3;50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE
CAS:1330-20-7
RTECS #:ZE2100000
Minumum % Wt:10.
Maxumum % Wt:30.
ACGIH TLV:434 MG/M3;100 PPM
ACGIH STEL:651 MG/M3;150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: LIVER & KIDNEY. SKIN:
NO HAZARD KNOWN TO BORDEN. INGESTION: NOT EXPECTED TO BE HARMFUL
UNDER NORMAL CONDITIONS OF USE. IF ACCIDENTALLY SWALLOWED BURNS OR
IRRITATION TO MUCOUS MEMBRANES , ESOPHAGUS OR GI TRACT CAN RESULT.
INHALATION: MAY BE HARMFUL IF INHALED, LIQUID OR VAPOR MAY CAUSE
IRRITATION TO NOSE, THROAT, AND LUNGS. CAN CAUSE CENTRAL NERVOUS
SYSTEM DEPRESSION. SKIN/EYES: CAU SES IRRITATION.
Explanation of Carcinogenicity:NONE SPECIFIED BY MANUFACTURER.
Effects of Overexposure:IF ACCIDENTALLY SWALLOWED BURNS OR IRRITATION
TO MUCOUS MEMBRANES, ESOPHAGUS OR GI TRACT CAN RESULT. HEADACHE,
DIZZINESS, NAUSEA, VOMITING, UNCONSCIOUSNESS AND ASPHYXIATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGESTION-IF ACCIDENTALLY SWALLOWED, DILUTE BY DRINKING LARGE
QUANTITIES OF WATER. IMMEDIATELY CONTACT POISON CONTROL OR HOSPITAL
EMERGENCY ROOM FOR ADDITIONAL TREATMENT DIRECTIONS.
INHALATION-REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION (MOUTH-TO-MOUTH). SKIN CONTACT-FLUSH WITH PLENTY OF
WATER. REMOVE CONTAMINATED CLOTHING. CALL A PHYSICIAN IF IRRITATION
PERSISTS. EYE CONTAC T-IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER
FOR AT LEAST 15 MINUTES. EYELIDS SHOULD BE HELD APART DURING
IRRIGATION TO INSURE WATER CONTACT WITH ENTIRE EYE. CALL A
PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:IN CASE OF FIRE, USE DRY CHEMICAL,FOAM OR CARBON
DIOXIDE.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE BUT SHOULD BE USED TO
KEEP FIRE EXPOSED CONTAINERS COOL.HIGH TEMPERATURES MAY CAUSE
BURSTING.
Unusual Fire/Explosion Hazard:EXTREMELY FLAMMABLE! AVOID OPEN FLAMES,
SPARKS, PILOT LIGHTS. DO NOT SMOKE. VAPORS MAY IGNITE EXPLOSIVELY.
SPRAY MIST OR VAPOR EVAPORATING FROM A DEPOSITED FILM IS HEAVIER
THAN AIR & MAY SETTLE IN LOW PLACES OR TRAVEL OUTWARDS TO A SOURCE
OF IGNITION & FLASHBACK. CONTENTS UNDER PRESSURE.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. SOAK UP WITH
ABSORBENT MATERIAL AND REMOVE TO CHEMICAL DISPOSAL AREA. PREVENT
ENTRY INTO NATURAL BODIES OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE AT TEMPERATURES ABOVE
120F.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE AIR CONTAMINANTS CAN EXCEED ACCEPTABLE
CRITERIA, USE NIOSH/MSHA APPROVED RESPIRATORY PROTECTION EQUIPMENT.
RESPIRATORS SHOULD BE SELECTED BASED ON THE FORM AND CONCENTRATION
OF CONTAMINANTS IN A IR IN ACCORDANCE WITH OSHA C29CFR1910.134 OR
OTHER APPLICABLE STANDARDS OR GUIDELINES.
Ventilation:LOCAL EXHAUST VENTILATION,ENCLOSED SYSTEM DESIGN,PROCESS
ISOLATION & REMOTE CONTROL IN COMBINATION WITH APPROPRIATE USE OF
PERSONAL PROTECTIVE EQUIPMENT.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V3
Vapor Pres:60 PSIG
Vapor Density:>AIR
Spec Gravity: BUTYL ACETATE
Solubility in Water:SLIGHT
Percent Volatiles by Volume:81-89
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OXIDES OF CARBON
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL, STATE PROVINCIAL,
AND FEDERAL REQUIREMENTS. EMPTY CONTAINER: MAY CONTAIN EXPLOSIVE
VAPORS. DO NOT CUT, PUNCTURE, WELD ON OR NEARBY. INCINERATION WILL
CAUSE CONTAINER TOBURST VIOLENTLY.
=================== MSDS Transport Information ===================
Transport Information:DOT CLASSIFICATION: ORM-D CONSUMER COMMODITY.
===================== Regulatory Information =====================
SARA Title III Information:67-64-1, ACETONE, 36.71%; 71-36-3, N-BUTYL
ALCOHOL, 1.00%; 73-98-3, METHYL ETHYL KETONE, 8.34%; 108-10-1,
METHYLISOBUTYL KETONE, 1.00%; 108-65-6, 2-PROPANOL 1-METHOXY
ACETATE, 7.51%; 108-88-3, TOLUENE , 1.68%; 1330-20-7, XYLENE MIXED
ISOMERS, 10.66%.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TONER RED 1503ZMR/1290/1290RE/1590/2290
Preparer's Name:TATESHI LITAKA
CAGE:89431
CAGE:89431
============= Composition/Information on Ingredients =============
Ingred Name:POLYESTER RESIN (TRADE SECRET)
Ingred Name:PIGMENT (RED) (I & II) (TRADE SECRETS)
Ingred Name:PROPENE POLYMERS, POLYPROPYLENE, POLYOLEFINE
CAS:9003-07-4
RTECS #:UD1842000
Ingred Name:SILICON DIOXIDE, CELITE 322
CAS:7631-86-9
RTECS #:VV3100000
Fraction by Wt: <1%
OSHA PEL:80 MG/CUM
ACGIH TLV:0.2 MG/CUM
Ingred Name:TITANIUM DIOXIDE, TIO2
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: <1%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (MOUSE): >5000 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:WHEN USED AS INTENDED, IT DOESN'T
REPRESENT ANY KNOWN HEALTH OR SAFETY HAZARD. MINIMAL RESPIRATORY
TRACT IRRITATION MAY OCCUR AS W/EXPOSURE TO LARGE AMOUNT OF ANY
NON-TOXIC DUST.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: RESPIRATORY TRACT IRRITATION.
======================= First Aid Measures =======================
First Aid:INGESTION: DILUTE STOMACH CONTENTS W/SEVERAL GLASSES OF
WATER. INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH W/WATER. SKIN:
WASH W/SOAP & WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:IF FIRE IS IN THE MACHINE, TREAT AS AN
ELECTRIC FIRE (DON'T USE WATER). AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:TONER IS A COMBUSTIBLE POWDER. WHEN
DISPERSED IN AIR, IT FORMS EXPLOSIVE MIXTURES.
================== Accidental Release Measures ==================
Spill Release Procedures:MINIMIZE DUSTING SITUATION & SWEEP UP OR
VACUUM.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM CONTACT W/OXIDIZING
MATERIALS. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS REQUIRED
Supplemental Safety and Health
PRODUCT CODES: PC/UA 945-261, 946-183, 946-156, 946-282. SIZES: 140G,
100G, 125G, & 70G. SOFTENING RANGE: 135C. FLAMMABLE LIMITS:
20G/CUM IN AIR (LOWER LIMIT).
================== Physical/Chemical Properties ==================
Vapor Pres:NEGLIGIBLE
Spec Gravity:1.1
Evaporation Rate & Reference:(BU AC = 1): NEGLIGIBLE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:FINE COLORED (RED) POWDER & SLIGHT MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:TEMPS >200C
Hazardous Decomposition Products:CO2, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:NO SPECIAL TECHNIQUES BEYOND NORMAL PRACTICE.
INSURE CONFORMITY W/FEDERAL, STATE, OR LOCAL REGULATIONS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:CHEMGLAZE M313 PART A
CAGE:OOO65
CAGE:OOO65
CAGE:76005
============= Composition/Information on Ingredients =============
Ingred Name:PIGMENTS
Fraction by Wt: 3%
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 36%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENEDIISOCYANATE (MIXED ISOMERS) (SARA III)
CAS:26471-62-5
RTECS #:NQ9490000
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:0.005PPM/0.02STEL;94
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Effects of Overexposure:INHAL:ANESTHETIC IRRIT OF THE RESPIRATORY TRACT
OR ACUTE NERVOUS SYS DEPRESSION CHARACTERIZED BY THE
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR.TREAT SYMPTOMATICALLY & CONSULT A
PHYS,SPLASH(EYES:FLUSH IMMED.W/LG AMTS OF WATER.CONSULT
PHYS.SPLASH(SKIN)WASH AFFECTED AREAS W/SOAP & WATER.REMOVE
CONTAMINATED CLOTHING.CON SULT A DR IF IRRIT
PERSISTS.INGESTION:DRINK 1-
===================== Fire Fighting Measures =====================
Flash Point:43 F SCC 6C
Lower Limits:1.2
Upper Limits:7.2
Extinguishing Media:WATER FOG,CO*2,DRY CHEMICAL,REG OR ALCOHOL-TYPE
FOAMS
Fire Fighting Procedures:FULL PROTECTIVE EQMT,INCLDING SELF-CNTND
BREATHING APPAR
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED.ISOLATE FR
HEAT,ELECTRICAL EQMT,SPARKS & OPEN FLAME.CLOSED CONTAINERS
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION.AVOID BREATHING
OF VAPORS.USE SELF-CNTND BRTHG EQMT.VENTILATE AREA.CONTAIN & REMOVE
W/INERT ABSORBENT & NONSPARKING TOOLS.AVOID CONTACT
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE IR USE NEAR HEAT OR OPEN
FLAMES.
Other Precautions:PREVENT PROLONGED OR REPEATED BREATHING OF VAP OR
SPRAY MIST.FREE DIISOCYANATE MAY CAUSE ALLERGIC RESPIRATORY
REACTION TO SENSITIZED PERSONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE ANSI APPRVD RESPIRATORY PROTECTIVE
EQPMT.SPRA MIST TOXIC IF INHA
Ventilation:SUFFICIENT VENTILAT,IN COL & PATTERN,SHD BE PROVID TO KEEP
Supplemental Safety and Health
EMER & 1ST AID CONTD.DRINK 1-2 GLASSES OF WATER. DO NOT INDUCE
VOMITTING! CONSULT A PHYSICIAN IMMEDIATELY. THIS IS PART A.
KEY1:F4.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:228-233 F
Vapor Pres:25/
Vapor Density:3.14
Spec Gravity:1.08
Evaporation Rate & Reference:N-BUTYL ACET=1 0.7
Solubility in Water:NONE
Percent Volatiles by Volume:41%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO*2,CO PLUS OXIDES OF NITROGEN
Conditions to Avoid Polymerization:ELEVATED TEMP,AMINES,ACIDS,HYDROXYL
OR OTHER ACTIVE HYDRO CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/LOCAL STATE & FEDERAL REGS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:567-573 LETTERPRESS
Preparer's Name:DICK KARBO
CAGE:KMADD
CAGE:KMADD
============= Composition/Information on Ingredients =============
Ingred Name:COPPER COMPOUND
Fraction by Wt: 17%
Ingred Name:BARIUM COMPOUNDS
Fraction by Wt: 2%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED CONTACT W/SKIN/EYES CAN
CAUSE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMEDIATELY W/WATER. SKIN: WASH AFFECTED AREA
W/SOAP & WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>200F
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: WIPE UP & STORE WIPERS IN UNDERWRITERS
APPROVED CONTAINERS. LARGE: SCOOP MATERIAL INTO SEALABLE
CONTAINERS. WIPE UP REMAINDER & STORE WIPERS IN UNDERWRITERS
APPROVED CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS.
Other Precautions:AVOID CONTACT W/SKIN, EYES & CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS REQUIRED
Ventilation:LOCAL EXHAUST
Work Hygienic Practices:WASH AFTER USE. REMOVE/LAUNDER CONTAMINATED
CLOTHING BEFORE REUSE. DON'T CONSUME FOOD/BEVERAGE WHERE PRODUCT IS
USED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:470-610F
Evaporation Rate & Reference:SLOWER THAN WATER
Solubility in Water:INSOLUBLE
Appearance and Odor:OILY
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SU 100 SERIES DUNCAN NONTOXIC GLAZE
Preparer's Name:SCOTT MATTISON
CAGE:21546
CAGE:21546
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONTOXIC. ABRASIVE, CAN SCRATCH EYES.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE. WILL NOT BURN.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP PROPERLY W/PAPER TOWELS & A WET
SPONGE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER SEALED.
Other Precautions:DON'T INHALE MIST. AVOID CONTACT W/EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF SPRAYING, DON'T INHALE MIST. USE RESPIRATOR
THAT IS NIOSH APPROVED FOR SPRAYS & MISTS.
Ventilation:LOCAL EXHAUST: RECOMMENDED. MECHANICAL (GENERAL):
RECOMMENDED WHEN SPRAYING.
Work Hygienic Practices:FOLLOW GOOD HYGIENE PRACTICES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Melt/Freeze Pt:M.P/F.P Text:1800F
Spec Gravity:1.3 TO 1.8
Appearance and Odor:COLORED LIQUID W/NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:PUT PAPER TOWEL IN TRASH & RINSE OUT SPONGE.
DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FP-1520 MAGNEFINE DEVELOPER
CAGE:MATSH
CAGE:MATSH
CAGE:MATSX
============= Composition/Information on Ingredients =============
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: <1%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:MAGNETITE % WT INCLUDES INGS 3
CAS:1309-38-2
RTECS #:OM4800000
Fraction by Wt: 65-70%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MANGANESE DIOXIDE; (FERRITE)
CAS:1313-13-9
RTECS #:OP0350000
OSHA PEL:5 MG/M3 MN CEILING
ACGIH TLV:5 MG/M3 MN
Ingred Name:ACRYLIC ACID BUTYL ESTER POLYMER WITH STYRENE; (RESIN) %
WT INCLUDES INGREDIENTS 5 & 6
CAS:25767-47-9
Fraction by Wt: 30-35%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PROPENE POLYMERS; (RESIN)
CAS:9003-07-4
RTECS #:UD1842000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BISPHENOL A PROPYLENE OXIDE FUMARATE; (RESIN)
CAS:39382-25-7
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICA, AMORPHOUS FUMED; (ADDITIVE)
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: <1%
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:HEALTH HAZARD IS MINIMAL BEING NEITHER
IRRITATING, CORROSIVE, VOLATILE, NOR TOXIC. MUTAGENICITY IS
NEGATIVE. CONTACT WITH EYES MAY RESULT IN MECHANICAL IRRITATION.
INHALATION OF DUST MAY IRRITATE MUCO US MEMBRANES. INGESTION MAY
RESULT IN GASTRIC DISTURBANCES.
Explanation of Carcinogenicity:CARBON BLACK: IARC MONOGRAPHS ON THE
EVALUATION OF CARCINOGENIC RISK OF CHEMICALS TO MAN, VOL 65,
1995:GROUP 2B.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IMMED WASH EYES W/RUNNING WATER FOR AT LEAST 15 MIN. IF
IRRIT DEVELOPS, GET MED ATTN. SKIN: WASH AFFECTED AREAS W/SOAP &
WATER. IF IRRIT DEVELOPS, GET MED ATTN. REMOVE & LAUNDER CONTAMD
CLTHG BE FORE REUSE. INGEST: IF SWALLOWED DILUTEW/WATER & IMMED
INDUCE VOMIT. GET MED ATTN IF VICTIM IS UNCONSCIOUS OR HAVING
CONVULSION. INHAL: REMOVE TO FRESH AIR AREA. AID IN BRTHG IF NEC &
GET MED ATTN.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP . NOT
FLAMMABLE OR COMBUSTIBLE BUT WILL BURN IF IGNITED. EXTINGUISH
W/WATER, CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Unusual Fire/Explosion Hazard:NONE UNDER NORMAL STORAGE AND USE
CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM OR SWEEP UP DRY POWDER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID DUST INHALATION AND SKIN
CONTACT.
Other Precautions:KEEP CONTAINERS CLOSED. STORE IN A COOL, DRY PLACE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL USE. USE NIOSH
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE REQUIRED UNDER NORMAL USE.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:MINIMIZE BREATHING DUST.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:2.5 (H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:FINE BLACK POWDER; PRACTICALLY ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:ABNORMALLY HIGH TEMPERATURE.
Hazardous Decomposition Products:NONE IN NORMAL HANDLING AND USE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:139 IRON STANDARD SOLUTION 1.00 MG/L FE
CAGE:4T252
CAGE:91224
CAGE:4T252
============= Composition/Information on Ingredients =============
Ingred Name:FERROUS CHLORIDE (SARA III)
CAS:7758-94-3
RTECS #:NO5400000
Fraction by Wt: <0.1%
OSHA PEL:1 MG FE/M3
ACGIH TLV:1 MG FE/M3; 9192
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:OTHER COMPONENT
Fraction by Wt: <1%
Ingred Name:WATER, H2O
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 100%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: IRRITATION. INGESTION:
PRACTICALLY NON-TOXIC.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN/EYES: IRRITATION. INGESTION: PRACXTICALLY
NON-TOXIC.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/PLENTY OF WATER. INGESTION: GIVE LARGE
QUANTITIES OF WATER OR MILK. CALL PHYSICIAN.
================== Accidental Release Measures ==================
Spill Release Procedures:ADD A LARGE EXCESS OF WATER W/STIRRING. ADJUST
THE PH TO NEUTRAL USING 6M HCL OR SODA ASH. FLUSH DOWN THE DRAIN
W/EXCESS WATER.
Neutralizing Agent:6M HCL OR SODA ASH
======================Handling and Storage ======================
Handling and Storage Precautions:STORE TIGHTLY CLOSED. WASH THOROUGHLY
AFTER HANDLING. AVOID CONTACT W/EYES, SKIN & CLOTHING.
============= Exposure Controls/Personal Protection =============
Ventilation:ADEQUATE VENTILATION
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:100C
Spec Gravity:0.988
pH:3.6
Evaporation Rate & Reference:0.84
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR, COLORLESS, LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT & EVAPORATION
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BURNT UMBER
Preparer's Name:WOODHALL STOPFORD
CAGE:72925
CAGE:72925
============= Composition/Information on Ingredients =============
Ingred Name:CADMIUM PIGMENT
Ingred Name:CADMIUM SUSPECTED HUMAN CARCINOGEN (ACGIH,IARC, & NTP)
INTENDED CHANGE (IC)
CAS:7440-43-9
RTECS #:EU9800000
Fraction by Wt: 0.05%
Other REC Limits:A2 CARCINOGEN
OSHA PEL:0.05 MG/CUM (CD)
ACGIH TLV:0.01 MG/CUM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:COBALT
CAS:7440-48-4
RTECS #:GF8750000
Other REC Limits:0.05 PPM
OSHA PEL:0.1 MG/CUM
ACGIH TLV:0.05 MG/CUM
Ingred Name:HEXACHLOROBENZENE
CAS:118-74-1
RTECS #:DA2975000
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:NICKEL (SOLUBLE) (SUSPECTED HUMAN CARCINOGEN BY NTP, IARC,
ACGIH) INTENDED CHANGE (IC)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 1.00%
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/CUM
ACGIH TLV:0.05 MG/CUM IC
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: MAY BE HARMFUL IF
SWALLOWED. CRONIC: EXPOSURE MAY CAUSE DAMAGE TO THE HEART/LUNGS.
EXPOSURE MAY CAUSE DAMAGE TOTHE CHEST. EXPOSURE MAY CAUSE HARM TO
THE DEVELOPING FETUS. LUNG DISEASE. KID NEY DISEASE. PREGNANCY.
HEART DISEASE.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:INGESTION: GET PROMPT MEDICAL ATTENTION. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
================== Accidental Release Measures ==================
Spill Release Procedures:NO SPECIAL SPILL PROCEDURES REQUIRED.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH-CERTIFIED MASK FOR DUSTS
Ventilation:LOCALLY EXHAUSTING HOOD
Work Hygienic Practices:DON'T SPRAY APPLY. WASH HANDS IMMEDIATELY AFTER
USE. WHEN USING DON'T EAT, DRINK/SMOKE. AVOID USING IF PREGNANT.
Supplemental Safety and Health
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE W/FEDERAL, STATAE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:604 WAVICIDE-06
CAGE:8G992
CAGE:8G992
============= Composition/Information on Ingredients =============
Ingred Name:TRIETHYLENE GLYCOL
CAS:112-27-6
RTECS #:YE4550000
Fraction by Wt: >1%K
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: SENSITIZATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NAUSEA, VOMITING, SYSTEMIC ILLNESS, IRRITATION.
======================= First Aid Measures =======================
First Aid:INGESTION: GIVE 2 GLASSES OF WATER. DON'T INDUCE VOMITING.
EYES: FLUSH W/PLENTY OF WATER. SKIN: FLUSH THOROUGHLY W/WATER.
INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:CO2, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:SCBA & PROTECTIVE CLOTHING SHOULD BE WORN WHEN
FIGHTING CHEMICAL FIRES.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH HEAVILY W/WATER. VENTILATE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMP, PREFERABLY IN A
COOL PLACE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN POORLY VENTILATED AREAS, NIOSH APPROVED
RESPIRATOR MAY BE REQUIRED.
Ventilation:LOCAL EXHAUST NEEDED TO AVOID EXPOSURE TO VAPORS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Spec Gravity:1.001-1.004
pH:6.35
Evaporation Rate & Reference:(BU AC=1): 1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, LIQUID W/SLIGHT ORANGE SCENT.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALINE CHEMICALS.
Stability Condition to Avoid:HIGH TEMPS.
Hazardous Decomposition Products:THERMAL: CO, CO2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CYANIDE NEUTRALIZER SOLUTION, A-3804
CAGE:7K791
CAGE:7K791
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM PHOSPHATE,MONOBASIC,DIHYDRATE
CAS:13472-35-0
Fraction by Wt: 22.5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 77.5%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE TOXICITY:IRRITATION. CHRONIC
TOXICITY:IRRITATION AND SENSITIZATION DERMATITIS.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:MAY CAUSE IRRITATION TO EYES, SKIN
AND MUCOUS MEMBRANES. MAY CAUSE DERMATITIS AND CONJUNCTIVITIS.
======================= First Aid Measures =======================
First Aid:EYES:IMMED FLUSH W/WATER FOR @ LEAST 15 MINUTES. SKIN:IMMED
FLUSH W/WATER FOR 15 MINUTES. INGEST:SEEK MED ATTENTION.
INHAL:REMOVE INDIVIDUAL TO FRESH AIR.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL, WATER SPRAY OR FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:PLACE IN SMALL CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PROD SHOULD BE STORED IN DARK & @ ROOM
TEMP; HOWEVER, TEMPS UP TO 120F/EVEN BELOW FREEZING WILL NOT
NORMALLY AFFECT REAGENT PERFORMANCE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:33.3F,1C
Vapor Density:MISCIBLE
Spec Gravity:>1.0
pH:4
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:MISCIBLE
Appearance and Odor:COLORLESS LIQUID, NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE TOXIC OXIDES OF PHOSPHOROUS AND SODIUM OXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE
AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:THE POUCH
CAGE:0G3N5
CAGE:0G3N5
============= Composition/Information on Ingredients =============
Ingred Name:ALL INGREDIENTS ARE NON HAZARDOUS
Fraction by Wt: NA
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: SLIGHT REDNESS ON HANDS &
FOREARMS IF INDIVIDUAL HAS HISTORY OF DERMAL ALLERGIC REACTIONS.
EYES: DUST/MIST MAY CAUSE IRRITATION OR INFECTION.
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/WATER & LIMIT EXPOSURE IF REDNESS DEVELOPS. WASH
HANDS THOROUGHLY AFTER HANDLING. EYES: FLUSH W/WATER AT LEAST 15
MINUTES. CONTACT PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NA
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:ALL TYPES
Fire Fighting Procedures:NONE KNOWN
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP OR FLUSH SMALL SPILLS INTO SEWER LINES.
IF LARGE SPILLS DRY, CONTAIN & COLLECT FOR REUSE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL DRY PLACE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DUST MASK SHOULD BE USED WHEN HANDLING LARGE
AMOUNTS.
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:LONG SLEEVES.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NA
Melt/Freeze Pt:M.P/F.P Text:NA
Decomp Temp:Decomp Text:NA
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:NA
pH:NA
Evaporation Rate & Reference:NA
Solubility in Water:DISPERSIBLE
Appearance and Odor:LIGHT BROWN GRANULAR POWDER, CHARACTERISTIC ODOR
Percent Volatiles by Volume:NA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INEFFECTIVE IF PRODUCT CONTACTS BLEACH OR GERMOCIDES.
Stability Condition to Avoid:BLENDING W/STRONG OXIDIZING AGENTS COULD
DECOMPOSE TO WATER & CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF BY FLUSHING W/WATER INTO SEWER LINES.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HEXANOIC ACID ETHYL ESTER, O-415
CAGE:84898
CAGE:84898
CAGE:8Y898
============= Composition/Information on Ingredients =============
Ingred Name:HEXANOIC ACID, ETHYL ESTER; (HEXANOIC ACID ETHYL ESTER)
CAS:123-66-0
RTECS #:MO7735000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT LENSES SHOULD NOT BE WORN IN
THE LABORATORY. ALL CHEMICALS SHOULD BE CONSIDERED HAZARDOUS-AVOID
DIRECT PHYSICAL CONTACT! CAN BE HARMFUL IF INHALED, SWALLOWED OR
ABSORBED THROUGH THE SKIN. DUST AND/OR VAPORS CAN CAUSE IRRITATION
TO RESPIRATORY TRACT.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMED . AN ANTIDOTE IS A SUBSTANCE INTENDED TO
COUNTERACT EFT OF POIS. IT SHOULD ADMIN ONLY BY MD/TRAINED EMER
PERS. MED ADVICE CAN BE OBTAINED FROM POIS CTL CTR. EYES:FLUSH
CONTI NUOUSLY W/WATER FOR AT LST 15 MIN. SKIN:FLUSH W/WATER FOR
15-20 MIN. IF NO BURNS HAVE OCCURRED-USE SOAP & WATER TO CLEANSE
SKIN. DO NOT WEAR SHOES/CLTHG UNTIL ABSOLUTELY FREE OF ALL CHEM
(SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point:120F,49C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER OR WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR APPROPRIATE OSHA-REGULATED
EQUIPMENT. VENTILATE AREA. ABSORB ON VERMICULITE OR SIMILAR
MATERIAL. SWEEP UP AND PLACE IN APPROPRIATE CONTAINER. HOLD FOR
DISPOSAL. WASH CONTAMINATED S URFACES TO REMOVE ANY RESIDUES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH SKIN, EYES AND
CLOTHING. KEEP TIGHTLY CLOSED AND STORE IN A COOL, DRY PLACE. STORE
ONLY WITH COMPATIBLE CHEMICALS.
Other Precautions:PERSONS NOT SPECIFICALLY & PROPERLY TRAINED SHOULD
NOT HNDL CHEM/ITS CNTNR. PROD IS FURNISHED FOR LAB USE ONLY! MFR'S
PRODS MAY NOT BE USED AS DRUGS, COSMETICS, AGRICULTURAL/PESTICIDAL
PRODS, FOOD ADD ITIVES/AS HOUSEHOLD CHEMS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . USE APPROPRIATE OSHA/MSMA APPROVED SAFETY
EQUIPMENT.
Ventilation:THIS CHEMICAL SHOULD BE HANDLED ONLY IN A HOOD.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC:ODORS. INHAL:REMOVE PATIENT TO FRESH AIR. ADMINISTER
OXYGEN IF PATIENT IS HAVING DIFFICULTY BREATHING. IF PATIENT HAS
STOPPED BREATHING ADMIN ARTIFICIAL RESPIRATION. IF PATIENT IS IN CA
RDIAC ARREST ADMIN CPR. CONTINUE LIFE SUPPORTING MEASURES UNTIL
MEDICAL ASSISTANCE HAS ARRIVED. GET MED ATTN IF NEC.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:334F,168C
Vapor Density:0.873
Solubility in Water:INSOLUBLE
Appearance and Odor:FRUITY, PERFUME LIKE, OR PLEASANT ODOR. COLORLESS
TO YELLOWISH LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE WITH STRONG ACIDS, STRONG BASES, STRONG REDUCING AGENTS
AND STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:DECOMPOSITION LIBERATES TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MIL-L-6082 GRADE 1100 (BASE OIL) D12-10
CAGE:JOINT
CAGE:JOINT
============= Composition/Information on Ingredients =============
Ingred Name:SILVER*96-2*
CAS:7440-22-4
RTECS #:VW3500000
OSHA PEL:0.01 MG/CUM
ACGIH TLV:0.1 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ALUMINUM*96-2*
CAS:7429-90-5
RTECS #:BD0330000
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:BORON *96-2*
CAS:7440-42-8
RTECS #:ED7350000
Ingred Name:COPPER (DUST & MIST), BRONZE POWDER *96-2*
CAS:7440-50-8
RTECS #:GL5325000
Other REC Limits:1 MG(CU)/M3 (DUST)
OSHA PEL:0.1 MG(CU)/M3 (FUME)
ACGIH TLV:0.2 MG/M3 (FUME)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CHROMIUM METAL, CHROMIUM, CHROME (CARCINOGEN BY NTP; IARC
GROUP 3) *96-2*
CAS:7440-47-3
RTECS #:GB4200000
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:IRON *96-2*
CAS:7439-89-6
RTECS #:NO4565500
Ingred Name:MAGNESIUM
CAS:7439-95-4
RTECS #:OM2100000
Ingred Name:NICKEL (SUSPECTED ANIMAL/HUMAN CARCINOGEN BY IARC GROUP 2B,
SUSPECTED CARCINOGEN BY NTP) *96-2*
CAS:7440-02-0
RTECS #:QR5950000
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/CUM
ACGIH TLV:0.05 MG/CUM IC
Ingred Name:SODIUM
CAS:15307-79-6
RTECS #:AG6310000
Ingred Name:LEAD, INORGANIC LEAD (IARC CARC GROUP 2B) *96-2*
CAS:7439-92-1
RTECS #:OF7525000
ACGIH TLV:0.15 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
ACGIH TLV:10 MG/CUM
Ingred Name:TIN *96-2*
CAS:7440-31-5
RTECS #:XP7320000
OSHA PEL:2 MG/CUM
ACGIH TLV:2.0 MG/CUM
Ingred Name:TITANIUM, DRY POWDER *96-2*
CAS:7440-32-6
RTECS #:XR1700000
Ingred Name:ZINC
CAS:7440-66-6
RTECS #:ZG8600000
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:MANGANESE *96-2*
CAS:7439-96-5
RTECS #:OO9275000
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM (DUST)
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 29,000 MG/KG
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:THIS PRODUCT MAY BE IRRITATING TO THE
EYES & MAY CAUSE SLIGHT SKIN IRRITATION.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:THIS PRODUCT MAY BE IRRITATING TO THE EYES &
MAY CAUSE SLIGHT SKIN IRRITATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE. EYES: WASH W/CLEAR WATER
FOR 15 MINS. SKIN: WASH W/SOAP & WATER. INGESTION: DON'T INDUCE
VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:420F,216C
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:TREAT AS AN OIL SPILL. CLEAN W/TOWEL/RAG.
DISPOSE OF RAG IN TRASH. DON'T STORE W/OXIDIZERS. FLOOR MAY BE
SLIPPERY. DETERGENT WASH MAY BE REQUIRED.
======================Handling and Storage ======================
Handling and Storage Precautions:USE NORMAL GOOD HOUSEKEEPING
PROCEDURES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY NEEDED UNLESS OIL MIST OCCURS THEN
USE DUST/MIST CARTRIDGE.
Ventilation:EXHAUST SYSTEM SHOULD BE IN PROPER WORKING ORDER TO FURNISH
NORMAL WORKPLACE VENTILATION.
Work Hygienic Practices:USE NORMAL GOOD HOUSEKEEPING PROCEDURES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Pres:0
Spec Gravity:0.9119
Solubility in Water:INSOLUBLE
Appearance and Odor:GOLDEN BROWN COLOR W/CHARACTERISTIC ODOR OF
LUBRICATING OIL
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Hazardous Decomposition Products:PARTIALLY BURNED HYDROCARBONS, METAL
OXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:SMALL: RESIDUES OF THESE PRODUCTS MAY BE
DISCARDED IN TRASH. MATERIAL MAY BE DISPOSED OF AS WASTE OIL IN
ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ALIPHATIC POLYISOCYANATE,383 BLACK ZENTHANE
CAGE:09225
CAGE:09225
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ISOAMYL KETONE
CAS:110-12-3
RTECS #:MP3850000
Fraction by Wt: 30-40%
Other REC Limits:NONE
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9293
Ingred Name:SILICA, AMORPHOUS, DUST
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: <0.5%
Other REC Limits:NONE
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3; 8990
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 20-30%
Other REC Limits:NONE
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: <1%
Other REC Limits:NONE
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:AROMATIC 100
CAS:64742-95-6
Fraction by Wt: 1-5%
Other REC Limits:50PPM (MFR)
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 1-5%
Other REC Limits:NONE
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:1,6-DIISOCYANATOHEXANE (HEXAMETHYLENE DIISOCYANATE)
CAS:822-06-0
RTECS #:MO1740000
Fraction by Wt: 0.05%
Other REC Limits:NONE
ACGIH TLV:0.005 PPM; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:HOMOPOLYMER OF HEXAMETHYLENE DIISOCYANATE
CAS:28182-81-2
RTECS #:NQ9170000
Fraction by Wt: 20-30%
Other REC Limits:1MG/M*3(MFR)
Ingred Name:IRON OXIDE
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 5-10%
Other REC Limits:NONE
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
Ingred Name:POLYESTER RESIN
Fraction by Wt: 1-5%
Other REC Limits:NONE
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CHRONIC OVEREXPOSURE TO ISOCYANATE
CONTAIN PRODUCTS MAY LEAD TO RESPIR SENSITIZATION CHARACTERIZED BY
ASTHMA-LIKE SYMP & OR SKIN SENSITIZATION CHARACTERIZED BY ALLERGIC
DERMATITIS(RASH,ITCH,HIVES,SWEL LING,ETC.).REPORTS HAVE ASSOCIATED
REPEATED & PROLONGED OVEREXPOSURE TO SOLVENTS WITH PERM BRAIN &
NERVOUS SYSTEM DAMAGE
Effects of Overexposure:IRRITATION TO SKIN, EYES & RESPIRATORY TRACT
(NOSE,THROAT,LUNGS).SYMPTOMS MAY BE WATERING EYES,DRYNESS OF
THROAT,COUGHING,HEADACHE,TIGHTNESS IN CHEST OR BURNING
SENSATION.HEADACHE,DIZZINESS OR NAUSEA MAY BE EXPERIENCED BY SOME
AS A RESULT OF EXPOSURE TO SOLVENTS.
Medical Cond Aggravated by Exposure:ASTHMA AND OTHER RESPIRATORY
AILMENTS; CHEMICAL SENSITIZATION
======================= First Aid Measures =======================
First Aid:VAPORS: REMOVE FROM EXPOSURE.RESTORE BREATHING.KEEP WARM &
QUIET.NOTIFY A PHYSICIAN.EYES: FLUSH IMMED WITH LARGE AMTS OF
RUNNING WATER FOR AT LEAST 15 MIN.TAKE TO A PHYSICIAN FOR MEDICAL
TREATMENT.SKI N: WASH AFFECTED AREA WITH SOAP & WATER.REMOVE
CONTAMINATED CLOTHING.CONSULT A PHYSICIAN.INGESTION: IF SWALLOWED,
CALL A PHYSICIAN IMMEDIATELY!!!
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:60F(15.6C)
Lower Limits:1.0
Extinguishing Media:FOAM, DRY CHEMICAL AND CO2
Fire Fighting Procedures:FULL PROTECT EQUIP WITH SELF-CONTAINED
BREATHING APPARATUS SHOULD BE WORN.DURING FIRE, IRRIT & HIGHLY
TOXIC GASES & SMOKE ARE PRESENT FROM DECOMP/COMBUST PRODS.
Unusual Fire/Explosion Hazard:VAPORS HEAVIER THAN AIR.CAN TRAVEL A LONG
DISTANCE ALONG GROUND AND FLASHBACK. CONTAINERS MAY EXPLODE IN HEAT
OF FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVAC NON-ESSENTIAL PERSONNEL.REMOVE ALL
SOURCES OF IGNITION.VENTILATE AREA.AVOID BREATH VAPORS.COVER SPILL
WITH INERT ABSORB.POUR LIQUID DECONTAM OVER SPILL-LET STAND 10
MIN-COLLECT MATERIAL.WASH DOWN AREA WITH DECONTAM & FLUSH SPILL
AREA WITH WATER.
Neutralizing Agent:0-10% AMM.HYDROXIDE,2-5% DETERGNT & BALANCE WATER,OR
A SOLN OF(SEE OTHER PRECAU)
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F OR BELOW 32F.
STORE LARGE QUANTITIES IN BUILDINGS DESIGNED TO COMPLY WITH OSHA
1910.106.
Other Precautions:(NEUTRALIZING) UNION CARBIDE'S TERGITOL TMN-10(20%)&
WATER(80%).DO NOT TAKE INTERNALLY.GROUND CONTAINER WHEN
POURING.AVOID FREE FALL OF LIQUID IN EXCESS OF FEW INCHES.USE WITH
ADEQUATE VENTILATION & R ESPIRATORY EQUIPMENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AIRLINE RESPIRATORS UNLESS AIR SAMPLING SHOWS
EXPOSURE TO BE BELOW OSHA LIMITS.THEN, EITHER CHEMICAL CARTRIDGE
RESPIRATORS OR AIRLINE RESPIRATORS ARE REQUIRED.USE SAME
PRECAUTIONS DURING MIXING OR WHE RE PAINT FUMES WOULD BE PRESENT.
Ventilation:GENERAL DILUTION/LOCAL EXHAUST VENTILATION TO KEEP AIR
CONTAMINANT BELOW CURRENT (SEE SUPPLEMENTAL DATA)
Other Protective Equipment:COVER AS MUCH OF EXPOSED SKIN AREA AS
POSSIBLE WITH APPROPRIATE CLOTHING. KEEP SKIN CREAM PROTECTED AREA
TO A MINIMUM
Work Hygienic Practices:WASH HANDS BEFORE EATING OR SMOKING. SMOKE IN
SMOKING AREAS ONLY.
Supplemental Safety and Health
APPLICABLE OSHA SAFETY AND HEALTH REQUIREMENTS IN MIXING, APPLICATION
AND CURING AREAS; AND TO REMOVE DECOMPOSITION PRODUCTS DURING
WELDING AND FLAME CUTTING ON SURFACES COATED WITH THIS PRODUCT.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:244F-350F
Vapor Pres:8.00
Vapor Density:>AIR
Spec Gravity:1.22
Viscosity:NO
Evaporation Rate & Reference:EQUAL TO BUTYL ACETATE
Solubility in Water:REACTS WITH WATER
Appearance and Odor:OPAQUE LIQUID, SOLVENT ODOR
Percent Volatiles by Volume:51.3
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER,ALCOHOLS,GLYCOL ETHERS,AMINES.
Stability Condition to Avoid:WATER CONTAMINATION
Hazardous Decomposition Products:BY FIRE: CO2, CO, OXIDES OF NITROGEN,
TRACES OF HYDROGEN CYANIDE, HEXAMETHYLENE DIISOCYANATE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL ENVIRONMENTAL CONTROL REGULATIONS. DECONTAMINATE CONTAINERS
PRIOR TO DISPOSAL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SPECTRA FILM
Preparer's Name:EAV KARGER
CAGE:DO536
CAGE:29556
CAGE:DO536
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 5-10% %
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BENZYL PICOLINIUM BROMIDE (NOT IN POLACHROME)
CAS:2654-66-2
Fraction by Wt: 1-5% %
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM SULFITE (NOT IN POLAPAN)
CAS:7757-83-7
RTECS #:WE2150000
Fraction by Wt: 0.5-1.5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:PENTYL PICOLINIUM BROMIDE (ONLY IN POLACHROME)
CAS:10551-21-0
Fraction by Wt: 1-5% %
Other REC Limits:NONE RECOMMENDED
Ingred Name:TETRAMETHYL REDUCTIC ACID
CAS:1889-96-9
Fraction by Wt: 7-13% %
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION-MAY BE AN IRRITANT.
SKIN/EYE/ INGESTION-CORROSIVE.
Explanation of Carcinogenicity:THIS PRODUCT IS NOT LISTED BY IARC, NTP
OR OSHA AS A CARCINOGEN, MUTAGEN, TERATOGEN OR NEUROTOXIN.
Effects of Overexposure:EYE CONTACT WITH DEVELOPER MAY CAUSE PERMANENT
EYE DAMAGE. MAY CAUSE BURNS TO SKIN AND MOUTH.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE-IMMEDIATELY FLUSH EYE WITH PLENTY OF WATER FOR AT LEAST
15 MIN. SEE PHYSICIAN. SKIN-FLUSH EFFECTED AREA WITH PLENTY OF
WATER. ORAL CONTACT-RINSE MOUTH IMMEDIATELY WITH PLENTY OF WATER.
DRINK WATER OR CITRUS JUICE TO DILUT OR NEUTRALIZEANY ALKALI THAT
MAY HAVE BEEN SWALLOWED. DO NOT INDUCE VOMITING. SEEK MEDICAL
ATTENTION IMMEDITELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:MIX DOESN'T BURN
Extinguishing Media:NONE SPECIFIED BY MANUFACTURER.
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:HANDLE FILM SO AS NOT TO BREAK DEVELOPER PODS
PRIOR TO FILM DEVELOPMENT. SMALL QUANTITIES OF DEVELOPER FLUID MAY
BE WIPED UP WITH A DAMP PAPER TOWEL USING CARE TO AVOID ANY SKIN OR
EYE CONTACT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:CONTAINS ALKALI
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED.
Ventilation:NOT NORMALLY REQUIRED.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NOTES TO PHYSICIAN: PROLONGED CONTACT WITH SKIN MAY PRODUCE ALKALI
BURNS.
================== Physical/Chemical Properties ==================
HCC:B1
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:1.1
pH:>13
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:DILUTABLE
Appearance and Odor:CREAM, WHITE, TAN, GREY OR PINK VISCOUS FLUID.
Percent Volatiles by Volume:85%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:PRODUCT (FILM PACK, PICTURE) IS NOT CLASSIFIED
OR REGULATED UNDER U.S. FEDERAL LAW AS "RCRA HAZARDOUS" BEFORE OR
AFTER PROCESSING.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:PR-1201-RLS
Kit Part:Y
CAGE:DO563
CAGE:83574
CAGE:DO563
============= Composition/Information on Ingredients =============
Ingred Name:LEAD PEROXIDE (LEAD DIOXIDE), (OSHA PEL FROM 29CFR
1910.1025)
CAS:1309-60-0
RTECS #:OG0700000
Fraction by Wt: 7%
OSHA PEL:0.05 MG/M3 (PB)
ACGIH TLV:0.15 MG/M3(PB); 8990
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 5%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:BASE COMPOUND MAY BE IRRITATING TO
SKIN.ACCELERATOR CONTNS LEAD COMPOUND WHICH MAY BE ABSORB THRU SK
======================= First Aid Measures =======================
First Aid:SKIN:WASH THOROUGHLY WITH SOAP & WATR. EYES:WASH OUT
THOROUGHLY W/LG AMTS OF WATR; SEE A PHYSICIAN INGESTION:INDUCE
VOMITING; SEE A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:92 F PMCC 33 C P
Lower Limits:1
Upper Limits:7
Extinguishing Media:FOAM,DRY CHEMICAL,XO*2.
Unusual Fire/Explosion Hazard:EMISSION OF TOXIC VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP EXCESS WITH RAGS OR PAPER TOWELS;
CLEAN AREA WITH XYLENE OR TOLUENE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN CLOSED CONTAINERS AT ROOM
TEMPERATURE. AVOID ACCELERATOR SPILLAGE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AIR-SUPPLIED RESPIRATOR RECOMMENDED IN CONFINED
AREAS.
Ventilation:LOC EXHAUST/MECHAN ADEQUATE TOMINIMIZE SOLVENT VAPOR.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
Spec Gravity:1.62
Solubility in Water:INSOLUBLE
Appearance and Odor:PINKISH BROWN,THICK LIQUID,SLIGHT TOLUENE ODOR.
Percent Volatiles by Volume:6%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
DECOMPOSES WHEN EXPOSED TO STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:OXIDES OF SULFUR;HYDROGEN SULFIDE;
FORMAL ACID.
==================== Disposal Considerations ====================
Waste Disposal Methods:NORMAL TRASH PROCEDURES; DO NOT INCINERATE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ZE-3 EMULSIFIER (POST 6/1989)
Kit Part:Y
Preparer's Name:BRUCE C. GRAHAM, CH. CHEM
CAGE:37676
CAGE:37676
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL (EXPOSURE REGULATED AS 'OIL MIST')
CAS:8012-95-1
RTECS #:PY8030000
Fraction by Wt: 50.0%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3/10 STEL;9192
Ingred Name:"NOT HAZARDOUS" INGREDIENTS
Fraction by Wt: 50%
Other REC Limits:NONE ESTABLISHED
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:ACUTE:MAY IRRITATE EYES:SEE
OVEREXPOSURE SYMPTOMS.
Effects of Overexposure:INHALATION: NOT LISTED BY MANUFACTURER;
HOWEVER,FINE SPRAY/MIST MAY IRRITATE BREATHING PASSAGES; EYES:
LIQUID/MIST CAUSES IRRITATION; SKIN: PROLONGED OR REPEATED CONTACT
CAUSES IRRITATION BY DISSOLVIN G SKIN OILS; INGESTION: CAUSES
GASTRIC UPSET.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY THE MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR; SKIN: REMOVE CONTAMINATED
CLOTHES.WASH OFF PROMPTLY WITH SOAP & WATER.USE SOOTHING LOTION.GET
MEDICAL HELP IF IRRITATION PERSISTS; EYES: IMMEDIATELY RINSE EYES
WITH CO PIOUS AMOUNT OF WATER.GET MEDICAL ASSISTANCE IF IRRIT ION
PERSISTS; INGESTION: DO NOT INDUCE VOMITING. GET MEDICAL ATTENTION
IF INGESTED.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:325F/162.8C
Extinguishing Media:CARBON DIOXIDE, FOAM
Fire Fighting Procedures:KEEP CONTAINERS COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:WHEN INVOLVE IN COMBUSTION,MAY EMIT TOXIC
GASES AT OR ABOVE DECOMPOSITION TEMPERATURE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES.SMALL SPILL:WIPE UP OR
MOP UP BUT DO NOT BREATHE VAPORS.PLACE RAGS IN CLOSED DRUMS; LARGE
SPILL: WEAR PERSONAL SAFETY EQUIPMENTS.DIKE AREA FAR AHEAD.ABSORB
LIQUID WITH COMMERCI AL ABSORBENT.TRANSFER WASTE MATL IN SALVAGE
TANKS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HEAT SOURCES IN WELL
VENTILATED AREA.AVOID AGAINST PHYSICAL DAMAGE TO CONTAINERS.KEEP
CONTAINERS TIGHTLY CLOSED.
Other Precautions:DO NOT BREATHE VAPORS.DO NOT SMOKE WHILE USING.DO NOT
HEAT ABOVE 130F(54C).AVOID FREQUENT OR PROLONGED SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATORS FOR CONFINED
AREAS.
Ventilation:GENERAL ROOM VENTILATION TO KEEP BELOW TLV LIMITS.
Other Protective Equipment:NOT KNOWN.
Work Hygienic Practices:WASH OFF PROMPTLY WITH WATER.AVOID SKIN
CONTACT.
Supplemental Safety and Health
NSN IS FOR A 2 PARTS SET OF MIL-I-25135E. I/A/W QPL-25135-15,THE SET OF
TYPE I,METHOD B,LEVEL 3 MAY CONSIST OF ZL-22D OR ZL-27A PENETRANT
AND ZE-3 OR ZE-4B EMULSIFIER. THIS ENTRY DESCRIBES ZE-3. SEE O THER
PN IND FOR OTHER PENETRANTS AND EMULSIFIERS.ALSO SEE QPL AND SPEC
FOR MORE DETAILS. KEY1:N1.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:450F/232.2C
Vapor Pres:0.3 @100F
Vapor Density:>1.0
Spec Gravity:0.945
pH:8.0
Solubility in Water:COMPLETE
Appearance and Odor:VISCOUS PINK LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NOT KNOWN TO MFR
Stability Condition to Avoid:HEAT,HIGH TEMPERATURES
Hazardous Decomposition Products:EMITS OXIDES OF CARBON IF BURNING.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR DISPOSE OF AS EPA HAZARDOUS WASTE
D001 (IGNITABLE WASTE),IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL,STATE,LOCAL REGULATIONS;IF LOCAL AUTHORITIES PROHIBIT
DUMPING RINSINGS DOWN THE SEWER,P URIFY RINSINGS WITH MAGNAFLUX
WASTEWATER TREATMENT
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:001-89-021 GASKET
CAGE:58156
CAGE:58156
CAGE:72433
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9293
Ingred Name:HYDROUS MAGNESIUM SILICATE
Other REC Limits:NONE RECOMMENDED
Ingred Name:NATURAL LATEX
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE:MINOR EYS/SKIN IRRITATION.
INGESTION- IRRITATION OF GI TRACT. INHALATION-IRRITATION OF
RESPIRATORY TRACT. CHRONIC: ASBESTOSIS, LUNG CANCER, &
MESOTHELIOMA, ALL OF WHICH ARE DISABLING AND FATAL D ISEASES OF THE
LUNG. INHALATION AND INGESTION OF ASBESTOS FIBERS MAY CAUSE CANCER
OF THE BOWEL.
Explanation of Carcinogenicity:ASBESTOS IS A KNOWN HUMAN CARCINOGEN.
Effects of Overexposure:INHALATION: FATIGUE AND SHORTNESS OF BREATH
THAT GETS WORSE WITH TIME AND EVENTUALLY BECOMES DISABLING. EYES:
IRRITATION. SKIN: IRRITATION. INGESTION: MILD STOMACH DISTRESS.
DIARRHEA, VOMITING, AND NA USEA.
Medical Cond Aggravated by Exposure:ASTHMA, EMPHYSEMA, AND TUBERCULOSIS
ARE ALL GENERALLY AGGRAVATED BY EXPOSURE TO ASBESTOS FIBERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SEE DOCTOR. EYES: RINSE
THOROUGHLY WITH WATER FOR 15 MINUTES. SEE DOCTOR. SKIN: WASH
THOROUGHLY WITH SOAP AND WATER. IF IRRITATION PERSISTS, SEE DOCTOR.
INGESTION: DIL UTE WITH WATER. DO NOT INDUCE VOMITING.SEE DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:NOT REQUIRED
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM THE MATERIAL WITH A HEPA FILTERED
VACUUM. THE EQUIPMENT SHALL BE USED & EMPTIED SO AS TO MINIMIZE THE
RE-ENTRY OF ASBESTOS INTO THE WORKPLACE. OTHERWISE, WET THE
MATERIAL WITH WATER & SURFACTAN T AND THEN SHOVEL OR MOP UP
CONTAMINATION.
======================Handling and Storage ======================
Handling and Storage Precautions:ITEM IS NONFRIABLE & WILL NOT SHED
FIBERS IN NORMAL USE AND STORAGE. USED ITEMS SHALL BE WETTED
BEFORE, DURING & AFTER DISASSEMBLY.
Other Precautions:IF IT IS NECESSARY TO CUT OR IMPACT THE ITEM WHILE
INSTALLING IT, WEAR A RESPIRATOR AND PROTECTIVE CLOTHING. USED
ITEMS SHALL BE IDENTIFIED AND DISPOSED OF IN ACCORDANCE WITH ALL
LOCAL, STATE AND FEDE RAL REGULATIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED HEPA RESPIRATOR IF
REQUIRED. WEAR SELF-CONTAINED BREATHING APPARATUS IF REQUIRED FOR
HIGH LEVELS OF CONTAMINATES.
Ventilation:LOCAL EXHAUST SUFFICIENT TO ENTRAIN ALL PARTICULATE
EMISSIONS. HEPA FILTER REQUIRED. NO LEAKS ON PRESSURE SIDE OF FAN.
Other Protective Equipment:USE COVERALLS OR DISPOSABLE CLOTHING.
Work Hygienic Practices:WET WORK TO THE DEGREE POSSIBLE. WASH HANDS
AFTER HANDLING ITEM. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:T6
Spec Gravity:2.5
Solubility in Water:INSOLUBLE
Appearance and Odor:LIGHT BLUE WITH NO ODOR
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG MINERAL ACIDS, AND STRONG ALKALIS
Stability Condition to Avoid:ACCUMULATIONS OF DUST
Hazardous Decomposition Products:ASBESTOS DUST
==================== Disposal Considerations ====================
Waste Disposal Methods:WET THE MATERIAL WITH WATER AND SURFACTANT.
PLACE IN 6 MIL THICK POLYETHYLENE PLASTIC BAG. PLACE THESE BAGS
INTO ANOTHER POLY BAG OR A SAFE PLACE UNTIL IT CAN BE SHIPPED TO AN
APPROVED DISPOSAL SITE. IDENTIFY WITH ASBESTOS CANCER WARNING
LABEL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:RED BARON
Preparer's Name:HENRY SIMMONS
CAGE:070V3
CAGE:070V3
============= Composition/Information on Ingredients =============
Ingred Name:1,3,5-TRIGLYCIDYL ISOCYANURATE
CAS:2451-62-9
RTECS #:XZ1994900
Minumum % Wt:3.
Maxumum % Wt:7.
Ingred Name:NUISANCE DUST
= Wt:100.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:(1, 3, 5-TRIGLYCIDYL ISOCYANURATE)
INGESTION: MODERATE TOXIC: SYMPTOMS ARE NOT FULLY KNOWN, MAY
INCLUDE LOSS OF APPETITE AND NOSE BLEEDING. INHALATION: IRRITATING
TO UPPER RESPIRATORY TRACT. MAY CAUS E NOSEBLEEDS. EYE CONTACT:
IRRITATING. SKIN CONTACT: IRRITATING. CAN BE ABSORBED THROUGH THE
SKIN IN HARMFUL AMOUNTS. EFFECTS SIMILAR TO
INGESTION.1,3,5-TRIGLYCIDYL ISOCYANURATE) IRRITATION OF EYES,
SKIN, AND RESPIRATORY TRACT; LOSS OF APPETITE, MAY CAUSE
NOSEBLEEDS; TOXIC BY INGESTION AND IF ABSORBED THROUGH THE SKIN.
PROLONGED OR REPEATED CONTACT MAY CAUSE SKIN SENSITIZATION.
Medical Cond Aggravated by Exposure:RESPIRATORY ILLNESS & DERMATITIS
MAY BE AGGRAVATED BY EXCESSIVE EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYE CONTACT: FLUSH WITH COOL WATER FOR 15 MINUTES,
OCCASIONALLY LIFTING LIDS TO ENSURE THOROUGH RINSING. SEEK MEDICAL
ASSISTANCE. SKIN CONTACT: WASH THOROUGHLY WITH SOAP AND WATER.
INHALATION: REMOV E FROM AREA TO FRESH AIR. INGESTION: DRINK 1 TO
2 GLASSES OF WATER AND INDUCE VOMITING BY PLACING FINGER AT BACK OF
THROAT. SEEK MEDICAL ASSISTANCE. SKIN CONTACT WASH THOROUGHLY WITH
SOAP AND WATER INHALATION: REMOVE FROM AREA TO FRESH AIR.
INGESTION: DRINK 1 OR 2 GLASSES OF WATER AND INDUCE VOMITING BY
PLACING FINGER BACK OF THROAT. SEEK MEDICAL ASSISTANCE.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG, DRY SAND
Fire Fighting Procedures:USE FULLY PROTECTIVE EQUIPMENT WITH
SELF-CONTAINING BREATHING APPARATUS.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP CAREFULLY OR USE EXPLOSION-PROOF
VACUUM CLEANER, THEN DISPOSE IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP ALL EQUIPMENT CLEAN AND PROPERLY
GROUNDED TO AVOID STATIC ELECTRICITY DISCHARGE. KEEP WORK AREAS
FREE OF DUST. AVOID EXCESSIVE SKIN CONTACT. DO NOT INGEST OR
INHALE. KEEP OUT OF REACH OF CHILDREN . STORAGE: KEEP CONTAINERS
SEALED AND AVOID STATIC ELECTRICITY DISCHARGES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:PROVIDE SUFFICIENT VENTILATION IN VOLUME AND
PATTERN TO KEEP AIR CONTAMINATION CONCENTRATION BELOW APPLICABLE
OSHA PERMISSIBLE EXPOSURE LEVELS OR ACGIH'S TLV TWA LIMIT.
Ventilation:USE A PROPERLY FITTED NIOSH/MSHA APPROVED MECHANICAL
RESPIRATOR OR MASK TO AVOID BREATHING DUST.
Other Protective Equipment:PROTECTIVE OVERALLS RECOMMENDED. REMOVE AND
WASH SOILED CLOTHING.
Supplemental Safety and Health
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
Hazardous Decomposition Products:FUMES MAY CONTAIN CO, CO2, NO2 OR
OTHER NITROGEN COMPOUNDS.
=================== Toxicological Information===================
Toxicological Information:1,3,5-TRIGLYCIDYL ISOCYANURATE RAT 440.00
ORAL
==================== Disposal Considerations ====================
Waste Disposal Methods:MANAGE OR DISPOSE IN ACCORDANCE WITH LOCAL,
STATE AND FEDERAL REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.
======================================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MIL-G-10924D GREASE #10,779
Preparer's Name:THOMAS G. MUSILLI
CAGE:JO986
CAGE:1V074
CAGE:JO986
============= Composition/Information on Ingredients =============
Ingred Name:CALCIUM 12 HYDROXYSTEARATE
CAS:3159-62-4
Fraction by Wt: 11.0%
Ingred Name:MINERAL OIL
CAS:64742-53-6
RTECS #:PY8036000
Fraction by Wt: 86.0%
Other REC Limits:5MG/CUM(OIL MIST)
Ingred Name:SULFURIZED ISOBUTYLENE
CAS:68511-50-2
Fraction by Wt: 1.0%
Ingred Name:CALCIUM SULFONATE
CAS:68783-96-0
Fraction by Wt: 2.0%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:ACUTE:IRRITATION OF EYES,SKIN AND
RESPIRATORY TRACT. CHRONIC:NO DATA AVAILABLE.
Medical Cond Aggravated by Exposure:PRE-EXISTING CONDITIONS MAY BE
WORSEN.
======================= First Aid Measures =======================
First Aid:INHALE:REMOVE TO FRESH AIR, GIVE CPR/O*2 IF
NEED;EYES/SKIN:FLUSH W LG AMTS H*2O FOR 15 MIN;INGEST:RINSE MOUTH;
GET MEDICAL ATTENTION FOR EYES, BREATHING DIFFICULTY, OR OTHER
SYMPTOMS OF OVEREXPOSURE.
===================== Fire Fighting Measures =====================
Flash Point:325F/163C(D-92)
Autoignition Temp:Autoignition Temp Text:350F
Extinguishing Media:WATER FOG,CO*2,DRY CHEMICAL,FOAM,EARTH OR SAND
Fire Fighting Procedures:WATER MAY CAUSE FROTHING;USE NIOSH APPROVED
SCBA IN CONF ARA
Unusual Fire/Explosion Hazard:NONE NOTED
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;USE SUITABLE
ABSORBENT MATERIAL AND RECOVER FOR PROPER DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY AND WELL VENTILLATED
AREA;KEEP AWAY FROM HEAT,SPARKS AND OPEN FLAMES.
Other Precautions:AVOID CONTACT WITH EYES AND SKIN;WASH THOROUGHLY
AFTER EACH USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR ORG
VAPORS/MIST IF ABOVE TLV.
Ventilation:MECH(GEN)OR LOCAL EXHAUST THAT PROVIDES ADEQUATE
VENTILATION
Other Protective Equipment:FULL WORK CLOTHING TO PREVENT REPEATED OR
PROLONGED CONTACT.
Supplemental Safety and Health
MSDS DATED:NIL
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:650F/343C
Spec Gravity:0.91
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER GREASE-BLAND
Percent Volatiles by Volume:0.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:EXTREME HEAT
Hazardous Decomposition Products:CO AND CO*2 IF INCOMPLETE COMBUSTION
Conditions to Avoid Polymerization:OPEN FLAMES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF COLLECTED MATERIAL IN ACCORDANCE WITH
LOCAL,STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
NIIN: 01-221-1384
Product ID: 78-6578-6000-9 3BRAND DRY SILVER FILM 7869
Cage: 1LF36
=======================================================
Contractor Summary
=======================================================
Cage: 39711
Cage: 4V902
Cage: 1LF36
=======================================================
Item Description Information
=======================================================
Item Manager: S9I
Unit of Issue: RO
Quantitative Expression: 00000000200FT
UI Container Qty: 1
Type of Container: ROOL
=======================================================
Ingredients
=======================================================
Cas: 25038-59-9
RTECS #: TR2725000
% Wt: 80-90
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Cas: 9002-89-5
RTECS #: TR8100000
% Wt: 3-7
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Cas: 2489-05-6
% Wt: 1-5
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 0.01 MG/M3 (AG)
ACGIH TLV: 0.01 MG/M3 (AG)
------------------------------
Cas: 9004-35-7
% Wt: 1-3
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Cas: 3507-99-1
% Wt: 0.5-1.5
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Cas: 7789-47-1
RTECS #: OV7415000
% Wt: <0.1
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 0.1 MG/M3 (HG)
ACGIH TLV: 0.05 MG/M3 (HG)
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50 (ORAL RAT) IS UNKNOWN
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: NO ADVERSE HEALTH EFFECTS ARE EXPECTED FROM SKIN/EYE
CONTACT, INHALATION OF THIS PRODUCT. INGESTION IS NOT A LIKELY ROUTE OF
EXPOSURE TO THIS PRODUCT.
Explanation Of Carcinogenicity: NONE OF THE CHEMICALS IN THIS PRODUCT IS LISTED
BY IARC, NTP OR OSHA AS A CARCINOGEN.
Signs And Symptions Of Overexposure: NO ADVERSE HEALTH EFFECTS ARE EXPECTED
FROM EXPOSUE TO THIS PRODUCT.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYE: NO MEDICAL TREATMENT NEEDED FROM CONTACT. SKIN: NO MEDICAL
TREAMENT NEEDED FOR CONTACT. INHALED: NO NEED FOR FIRST AID ANTICIPATED.
INGESTED: NO NEED FOR FIRST AID IS ANTICIPATED.
=======================================================
Handling and Disposal
=======================================================
Waste Disposal Methods: RECLAMATION OF SILVER AND/OR PAPER IS PREFERRED,
ESPECIALLY FOR LARGER QUANTITIES. DISPOSE OF IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL REGULATIONS.EPA WASTE NUMBER=D009.
MERCURY CONT ENT IS ABOUT: 205 PPM BY WEIGHT.
Handling And Storage Precautions: STORE IN A COOL, DRY PLACE.
Other Precautions: PROCESS FILM IN A WELL-VENTILATED AREA. MAINTAIN REGULAR
SERVICING BY AN AUTHORIZED SERVICE TECHNICIAN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: USE WATER, CARBON DIOXIDE, OR DRY CHEMICAL
Fire Fighting Procedures: FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER SPRAY TO
COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard: NONE EXPECTED
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE NORMALLY REQUIRED.
Ventilation: USE IN A WELL-VENTIALTED AREA.
Other Protective Equipment: NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices: WASH HANDS AFTER HANDLING AND BEFORE EATING OR
DRINKING.
Supplemental Safety and Health: USE AS DIRECTED.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
Decomp Text: UNKNOWN
Solubility in Water: SLIGHT
Appearance and Odor: TRANSPARENT FILM, BLUE TINT, ESSENTIALLY ODORLESS
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: AVOID EXPOSURE TO LIGHT, ELEVATED TEMPERATURES,
OR HIGH HUMIDITY PRIOR TO EXPOSURE
Materials To Avoid: NONE NOTED
Hazardous Decomposition Products: CARBON DIOXIDE AND CARBON MONOXIDE,MERCURY
COMPOUNDS,SILVER COMPOUNDS,HYDROCARBONS,AND HYDROGEN BROMIDE
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 116187
Product ID: 78-6578-6000-9 3BRAND DRY SILVER FILM 7869
Review Date: 07/13/1993
Net Unit Weight: UNKNOWN
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: RO
Container QTY: 1
Type Of Container: ROOL
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: 78-6578-6000-9 3BRAND DRY SILVER FILM 7869
Cage: 1LF36
Company Name: MINNESOTA MINING AND MFG CO OFFICE SUPPLIES DIV
Street: 3M CTR
Zipcode: 55144-1000
Date Of Label Review: 07/13/1993
Status Code: C
Label Date: 07/13/1993
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HYSOL ES-4096, PART C, EZ4096
Kit Part:Y
Preparer's Name:RICHARD L. HALL
CAGE:57294
CAGE:12405
CAGE:57294
============= Composition/Information on Ingredients =============
Ingred Name:SILICONE RESIN (CONTAINING ING 2)
Fraction by Wt: 60-100%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TOLUENE (SARA 313) (CERCLA)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 40%
OSHA PEL:200 PPM
ACGIH TLV:50 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOLATILE ORGANIC COMPOUNDS: 40% BY WT.
RTECS #:9999999VO
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:MAY CAUSE IRRIT. SKIN:SINGLE
RELATIVELY SHORT EXPOS (<24 HRS) IRRITATES. RPTD PRLNG CONT (24-48
HRS) IRRITATES SERIOUSLY, MAY BURN MILDLY. INHAL:SHORT EXPOS MAY
CAUSE DROW & IRRITATE NOSE & THROA T. DEGREE OF EFTS DEPENDS ON
CONC & LENGTH OF EXPOS. INGEST:SM AMTS TRANSFERRED TO MOUTH BY
FINGERS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:DURING USE, ETC, SHOULD NOT INJURE.
SWALLOWING LG AMTS MAY INJURE SLIGHTLY. PRLNG TOLUENE OVEREXP MAY
INJURE LUNGS, BLOOD, LIVER, KIDNEYS & NERS SYS. NOTE:TOLUENE
APPEARS ON NAVY LIST OF OCCU P CHEM REPRO HAZS. SEEK CONSULTATION
FROM APPROP HLTH PROFESSIONALS CONCERNING LATEST HAZ LIST INFO &
SAFE HNDLG(SUPDAT)
Medical Cond Aggravated by Exposure:PROLONGED TOLUENE OVEREXPOSURE MAY
AGGRAVATE EXISTING EYE, SKIN & RESPIRATORY DISORDERS.
======================= First Aid Measures =======================
First Aid:EYES:IMMED FLUSH W/WATER FOR AT LST 15 MINS. SKIN:IMMED WIPE
OFF & FLUSH W/WATER. GET MED ATTN IF IRRIT DEVELOPS. INHAL:REMOVE
TO FRESH AIR. GET MED ATTN IF ILL EFTS PERSIST. INGEST:GET MED ATTN
IF LG AMT SWALLOWED. DO NOT INDUCE VOMIT. INHALING LIQ WHILE VOMIT
CAN INJURE LUNGS SERIOUSLY. IF SPONT VOMIT OCCURS, KEEP HEAD BELOW
HIPS TO PREVENT ASPIRATION OF LIQUID INTO LUNGS.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:40.0F,4.4C
Lower Limits:1.2%
Upper Limits:7.1%
Extinguishing Media:WATER, WATER FOG, CO*2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR & CAN TRAVEL
ALONG GROUND TO REMOTE IGNITION SOURCES.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE PRODUCT & USE ABSORBENT MATERIAL TO
TAKE CARE OF ANY OIL-LIKE RESIDUES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS IN A COOL,
DRY AREA AWAY FROM HEAT. USE ONLY W/ADEQUATE VENTILATION.
Other Precautions:AVOID PROLONGED OR REPEATED BREATHING OF VAPORS OR
CONTACT W/SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR PROPERLY FITTED NIOSH/MSHA APPRVD
SCBA/INDUS TYPE CANISTER MASK IN ENCLSD AREAS W/POOR OR NO VENT
SYS. IF AIR CONTAM IS SUSPECTED, CONTAM SHOULD BE VARIFIED BY AIR
MONITORING BEFORE SELECTION OF RESP PROT EQUIP IS MADE.
Ventilation:LOCAL EXHAUST &/OR MECHANICAL: RECOMMENDED.
Other Protective Equipment:HYDROCARBON INSOLUBLE APRONS, EYE WASH &
SAFETY SHOWER MEETING ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:EXPOSURE INFORMATION . EYE PROT:& FULL LENGTH
FACESHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:230F,110C
Vapor Pres:25
Vapor Density:3.1
Spec Gravity:1.08
Evaporation Rate & Reference:<1
Solubility in Water:<0.1%
Appearance and Odor:LIQUID, SOME COLOR; SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS CAN CAUSE A REACTION.
Hazardous Decomposition Products:SILICON DIOXIDE, CARBON DIOXIDE &
TRACES OF INCOMPLETELY BURNED CARBON PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF MATERIAL I/A/W LOCAL, STATE & FEDERAL
REGULATIONS CONCERNING HEALTH & POLLUTION. SHOULD BE REVIEWED TO
DETERMINE APPROVED DISPOSAL PROCEDURES. CONTACT DOW CORNING IF
THERE ARE ANY DISPOSAL QUESTIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:NA-SUL BSN/PAO
CAGE:OO176
CAGE:OO176
============= Composition/Information on Ingredients =============
Ingred Name:POLY-ALPHA-OLEFIN
Fraction by Wt: 50%
Other REC Limits:TLV=5 MG/CUM
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BARIUM DINONYLNAPHTHALENESULFONATE (LD50=3.5 G/KG (MFR))
Fraction by Wt: 50%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE HEALTH HAZARDS
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE IRRITATION (RABBITS):CORROSIVE TO
THE EYE. SKIN IRRITATION (RABBITS):MODERATE PRIMARY SKIN IRRITANT.
ACUTE INHALATION (RATS):LC50 >21 ML/L. ACUTE ORAL TOXICITY
(RATS):LD50 3.5 ML/KG.
Explanation of Carcinogenicity:N/A
Effects of Overexposure:DANGER:CORROSIVE TO THE EYES.
WARNING:IRRITATING TO THE SKIN.
Medical Cond Aggravated by Exposure:N/K
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/LGE AMT OF LUKEWARM H*2O FOR 15 MIN.IF MATL IS
NOT EASILY FLUSH FROM EYE,RINSE W/USP MINERAL OIL TO DISSOLVE
PROD.FOLLOW W/ISOTONIC SALINE.CONSULT MD.SKIN:WASH W/SOAP&H*2O &
RINSE WELL.IF IRRIT PERSIST,CONSULT MD.INGEST:IF CONSCIOUS,GIVE
LGE QTY OF H*2O.DO NOT INDUCE VOMIT.NEVER INDUCE VOMIT OR GIVE LIQ
TO UNCON PER.CONSULT MD.INHAL:RMV TO FRESH AIR.OTHER:WASH CONTAM
CLTHG BFR REUSE.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:419F (215 C)
Lower Limits:N/K
Upper Limits:N/K
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . COOL CONTAINERS WITH WATER IF EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:TREAT LIKE PETROLEUM FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL AMOUNTS:ADD OIL ABSORBENT, SHOVEL UP AND
PLACE IN CLOSED CONTAINERS FOR DISPOSAL. LARGE AMOUNTS:DIKE TO
CONTAIN AND PUMP INTO DRUMS FOR USE OR DISPOSAL.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY CLOSED WHEN
NOT IN USE.
Other Precautions:DO NOT ALLOW EYE CONTACT. AVOID SKIN CONTACT. DO NOT
INGEST. WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING, DRINKING
OR SMOKING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF MISTING OCCURS, USE NIOSH/MSHA APPROVED
RESPIRATOR FOR OIL MIST.
Ventilation:PROVIDE GENERAL, MECHANICAL VENTILATION.
Other Protective Equipment:EYEWASH FOUNTAINS AND SAFETY SHOWERS SHOULD
BE EASILY ACCESSIBLE.
Work Hygienic Practices:N/K
Supplemental Safety and Health
N/D=NOT DETERMINED. PH, HAZARDOUS POLYMERIZATION OCCUR, ROUTES OF ENTRY
& CARCINOGENITY:FP N.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:N/D
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:NEGLIGIBLE
Spec Gravity:0.98
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Solubility in Water:INSOLUBLE
Appearance and Odor:VISCOUS BROWN LIQUID, MILD ODOR
Corrosion Rate:
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:N/K
Hazardous Decomposition Products:THERMAL DECOMPOSITION & BURNING MAY
YIELD CARBON MONOXIDE, CARBON DIOXIDE, SULFUR OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS MATERIAL IS A HAZARDOUS WASTE DUE TO ITS
BARIUM CONTENT. DISPOSE OF AS SUCH IN THE MANNER PRESCRIBED IN
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:B0252 BORIC ACID
CAGE:21076
CAGE:21076
============= Composition/Information on Ingredients =============
Ingred Name:BORIC ACID, ORTHOBORIC ACID
CAS:10043-35-3
RTECS #:ED4550000
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 2660 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF SWALLOWED, INHALED/ABSORBED
THROUGH SKIN. CAUSES EYE & SKIN IRRITATION. INHALATION: MATERIAL IS
IRRITATING TO MUCOUS MEMBRANES & UPPER RESPIRATORY TRACT. MAY
AFFECT THE CNS, KIDNEYS, MALE & FEMALE REPRODUCTIVE SYSTEM. DEATH
HAS BEEN REPORTED TO OCCUR.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, NAUSEA, VOMITING, DIARRHEA,
ABDOMINAL CRAMPS, ERYTHEMATOUS LESIONS ON SKIN, MUCOUS MEMBRANES,
CIRCULATORY COLLAPSE, TACHYCARDIA, CYANOSIS, DELIRIUM, CONVULSIONS,
COMA
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/COPIOUS AMOUNTS OF WATER FOR 15
MINS. SKIN: WASH W/SOAP & COPIOUS AMOUNTS OF WATER. INHALATION:
REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NECESSARY. INGESTION: WASH
OUT MOUTH W /WATER IF CONSCIOUS. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, DRY CHEMICAL POWDER/APPROPRIATE FOAM
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS &
PROTECTIVE COTHING TO PREVENT CONTACT W/SKIN & EYES.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR SELF CONTAINED BREATHING
BAG & HOLD FOR WASTE DISPOSAL. AVOID RAISING DUST. VENTILATE AREA &
WASH SITE AFTER MAT ERIAL PICKUP IS COMPLETE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP
EYE/FACE PROTECTION.
Other Precautions:DON'T BREATHE DUST. DON'T GET IN EYES, ON SKIN/ON
CLOTHING. AVOID PROLONGED/REPEATED EXPOSURE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:PROTECTIVE CLOTHING, SAFETY SHOWER, EYE BATH
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Pres:2.6
Spec Gravity:1.435
Appearance and Odor:WHITE CRYSTALLINE POWDER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
POTASSIUM ANHYDRIDES
Stability Condition to Avoid:FIRE
Hazardous Decomposition Products:BORON OXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PENETRATING OIL TYPE I
Preparer's Name:IRIS CHARMS
CAGE:82925
CAGE:82956
CAGE:82925
============= Composition/Information on Ingredients =============
Ingred Name:ALIPHATIC PETROLEUM SOLVENT
CAS:8008-20-6
RTECS #:OA5500000
Fraction by Wt: 50%
Other REC Limits:NONE SPECIFIED
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED LIGHT
NAPHTHENIC/PETROLATUM
CAS:64742-53-6
RTECS #:PY8036000
Fraction by Wt: SEE # 3%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:HYDROTREATED HEAVY NAPHTHENIC DISTILLATE, PETROLEUM (%
SHOWN IS FOR INGREDIENTS NUMBER 2 AND 3)
CAS:64742-52-5
RTECS #:PY8035000
Fraction by Wt: 50%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:ADDITIVES PACKAGE
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRITATING TO BODY TISSUES. IF
INHALED MAY CAUSE CENTRAL NERVOUS SYSTEM EFFECTS. CHRONIC: SKIN
DEFFATING AND DERMATITIS.
Effects of Overexposure:INHALE:HEADACHE, DIZZINESS. INGEST:NAUSEA
EYES:IRRITATION.
Medical Cond Aggravated by Exposure:NO DATA AVAILABLE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES. IF IRRITATION
PERSISTS, SEE DOCTOR. SKIN: WASH WITH SOAP AND WATER. IF ADVERSE
SYMPTOMS DEVELOP, SEE DOCTOR. INHALATION: REMOVE TO FRESH AIR.
TREAT SYMPTOMATICAL LY. INGESTION: DO NOT INDUCE VOMITING. SEEK
MEDICAL ASSISTANCE.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:151F,66C
Lower Limits:0.58
Upper Limits:4.45
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE. DO NOT USE
WATER DIRECTLY AS IT MAY SPREAD A BURNING WATER SLICK.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS. KEEP UNINVOLVED CANS
COOL AND AWAY FROM HEAT OF FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. ABSORB W/
NONCOMBUSTIBLE ABSORBANT. PLACE IN SUITABLE METAL CONTAINER FOR
WASTE DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE. DO NOT HANDLE/STORE NEAR HEAT, SPARKS, OPEN FLAMES. KEEP AWAY
FROM OXIDANTS. DO NOT SPLASH WHEN POURING.
Other Precautions:AVOID BREATHING VAPORS. DISCARD ANY OIL CONTAMINATED
CLOTHING. DISEMINATE THE INFORMATION ON THIS MSDS TO ALL WHO MAY
USE THIS PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. USE SUPPLIED AIR-
RESPIRATORY PROTECTION IN CONFINED OR ENCLOSED SPACES.
Ventilation:USE LOCAL EXHAUST VENTILATION TO KEEP EXPOSURE LEVEL BELOW
PEL/TLV.
Other Protective Equipment:IMPERVIOUS APRON,EYE-WASH FOUNTAIN,SAFETY
SHOWER.
Work Hygienic Practices:WASH HANDS AND FACE AFTER USING. LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NONE.
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:338F,170C
Vapor Pres:1MM HG
Spec Gravity:0.81
Viscosity:1.5-10 CST
Solubility in Water:NEGLIGIBLE
Appearance and Odor:PALE YELLOW LIQUID,PETROLEUM LIKE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS (LIQUID CHLORINE, CONCENTRATED OXYGEN, SODIUM OR
CALCIUM HYPOCHLORITE)
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:950001
Kit Part:Y
CAGE:0AUB2
CAGE:70355
CAGE:0AUB2
CAGE:59233
============= Composition/Information on Ingredients =============
Ingred Name:BARIUM SULFATE
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: 7%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9596
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9596
Ingred Name:ZINC (SARA 313) (CERCLA)
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:GRAPHITE, NATURAL
CAS:7782-42-5
RTECS #:MD9659600
Fraction by Wt: 2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MPPCF; Z-3
ACGIH TLV:2 MG/M3 RDUST; 9596
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE DISCOMFORT DUE
TO DUST CONCENTRATION ABOVE THE PEL. THIS CONDITION IS REVERSIBLE
UPON CESSATION OF EXPOSURE.
Effects of Overexposure:EXPOSURE TO DUST CONCENTRATIONS ABOVE THE OSHA
PEL MAY CAUSE IRRITATION TO EYES AND BREATHING PASSAGES.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:SKIN: WASH WITH SOAP AND WATER. EYES: USE EYEWASH TO REMOVE
FROM EYES.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID CREATING DUST. VACUUM PROMPTLY. MAINTAIN
AIRBORNE CONCENTRATIONS BELOW THE OSHA PEL.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CREATING DUST. IF THE OSHA PEL
IS EXCEEDEED, US RESPIRATORS IN ACCORDANCE WITH CFR 1910.1025
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE OSHA APPROVED RESPIRATORY EQUIPMENT IF OSHA
PEL IS EXCEEDED.
Ventilation:LOCAL EXHAUST RECOMMENDED.
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:ENSURE AIRBORNE CONCENTRATIONS OF DUST DO NOT
EXCEED THE OSHA PEL.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:2.05
Appearance and Odor:DARK COLOR (SHINY), MODERATE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE WITH LOCAL AND OSHA/EPA RULES AND
REGULATIONS.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MS-242 QUICK-FREEZE
Preparer's Name:SOHEILA BURKE
CAGE:18598
CAGE:18598
============= Composition/Information on Ingredients =============
Ingred Name:CHLORODIFLUOROMETHANE
CAS:75-45-6
RTECS #:PA6390000
Fraction by Wt: 100%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1000 PPM
ACGIH TLV:1000PPM; 9192
Ozone Depleting Chemical:2
===================== Hazards Identification =====================
LD50 LC50 Mixture:LC50 INHALATION(4 HOUR)RAT 220,000 PPM
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: VAPOR IS HEAVIER THAN AIR
AND CAN CAUSE SUFFOCATION BY REDUCING OXYGEN AVAILABLE FOR
BREATHING. BREATHING HIGH CONCENTRATIONS OF VAPOR MAY CAUSE
LIGHT-HEADEDNESS, GIDDINESS, SHORTNESS OF B REATH, AND MAY LEAD TO
NARCOSIS, CARDIACIRREGULARITIES, UNCONSCIOUSNESS OR DEATH.
SKIN/EYE: IRRITATION AND FROSTBITE.
Explanation of Carcinogenicity:FREON 12 IS NOT LISTED AS A CARCINOGEN
BY IARC, NTP OR OSHA.
Effects of Overexposure:BREATHING HIGH CONCENTRATIONS OF VAPOR MAY
CAUSE LIGHT-HEADEDNESS, GIDDINESS, SHORTNESS OF BREATH, AND MAY
LEAD TO NARCOSIS, CARDIAC IRREGULARITIES, UNCONSCIOUSNESS OR DEATH.
LIQUID IS IRRITATING TO S KIN AND EYES, AND MAY CAUSE FROSTBITE.
Medical Cond Aggravated by Exposure:PERSONS WITH KNOWN HISTORY OF HEART
DISEASE OR IRREGULARITIES OF HEARTBEAT SHOULD BE PARTICULARY
CAREFUL TO AVOID OVEREXPOSURE TO THESE VAPORS.
======================= First Aid Measures =======================
First Aid:INALATION: REMOVE TO FRESH AIR, CALL A PHYSICIAN. IF NOT
BREATHING, GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT,
GIVE OXYGEN. DO NOT GIVE EPINEPHRINE OR SIMILAR DRUGS. EYE: FLUSH
WITH WATERFOR AT LEAST 15 MINUTES. GET MEDICAL ATTENTION. SKIN:
WASH WITH SOAP AND WATER. IF FROSTBITE, WARM SKIN SLOWLY. GET
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:NONE
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:CONTAINERS WILL EXPLODE IN THE HEAT OF
FIRE. COMBUSTION OR HEAT OF FIRE MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. KEEP UPWIND, EVACUATE ENCLOSED
SPACE. DISPERSE GAS WITH FLOOR-LEVEL FORCED AIR VENTILATION OR
WATER SPRAY. DO NOT SMOKE. REMOVE FLAMES, HEATING ELEMENTS, GAS
ENGINES, ETC.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A CLEAN, COOL, DRY AND
WELL-VENTILATED AREA OF LOW FIRE RISK. PROTECT CONTAINERS FROM
PHYSICAL DAMAGE AND KEEP TIGHTLY CLOSED.
Other Precautions:AVOID BREATHING VAPOR, LIQUID CONTACT WITH EYES, SKIN
OR CLOTHING. DO NOT DROP, REUSE, OR REFILL CONTAINER. DO NOT STORE
NEAR HEAT OR IN DIRECT SUN. KEEP CONTAINERS BELOW 120 F. READ LABEL
BEFORE USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED FOR ADEQUATELY VENTED WORK
SITUATIONS. FOR ACCIDENTAL OR NON-VENTILATED SITUATIONS, USE A
SELF-CONTAINED BREATHING APPARATUS OR SUPPLIED-AIR RESPIRATOR,
APPROVED BY NIOSH.
Ventilation:PROVIDE LOCAL AND MECHANICAL EXHAUST WHEN USED.
Other Protective Equipment:USE IMPERVIOUS CLOTHING TO PROTECT EXPOSED
SKIN FROM LIQUID CONTACT.
Work Hygienic Practices:DO NOT SMOKE IN AREA WHILE PRODUCT IS IN USE.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:V2
Boiling Pt:=-40.6C, -41.F
Melt/Freeze Pt:M.P/F.P Text:LIQ GAS
Vapor Pres:151 PSIA
Vapor Density:3.03
pH:NEUTRL
Evaporation Rate & Reference:>1
Solubility in Water:0.3%, NEGLIGIBLE
Appearance and Odor:COLORLESS,LIQUIFIED GAS, SLIGHT EHTEREAL ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALI OR ALKALINE EARTH METALS, POWDERED AL,BE,ZN, ETC.
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:DECOMPOSED BY HIGH TEMPERATURES (OPEN
FLAMES, GLOWING METAL SURFACES, ETC.) FORMING HYDROCHLORIC AND
HYDROFLUORIC ACIDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:BEST TO RECYCLE OR RECLAIM, IF POSSIBLE. MAY BE
INCINERATED IN OIL-FIRED FURNACE, BUT TOXIC AND CORROSIVE
COMBUSTION GASES MUST BE HANDLED. CONSULT FEDERAL, STATE, OR LOCAL
AUTHORITIES FOR PROPER DISP OSAL PROCEDURES.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LACQUER SPRAY PAINT,BLACK 17038
CAGE:91794
CAGE:91794
============= Composition/Information on Ingredients =============
Ingred Name:METHYLENE CHLORIDE(DICHLOROMETHANE) (SARA III)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 33.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM; Z-2
ACGIH TLV:50 PPM, A2; 9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:NAPHTHA (PETROLEUM SPIRITS OR BENZIN)
CAS:8030-30-6
RTECS #:SE7555000
Fraction by Wt: 16%
OSHA PEL:100 PPM
Ingred Name:ISOBUTANE-PROPANE(50-50 MOL WT%)
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 2.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM; Z-2
ACGIH TLV:S, 50 PPM; 9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BUTYL CELLOSOLVE
RTECS #:EP3600000
Fraction by Wt: 1.5%
ACGIH TLV:50PPM
===================== Hazards Identification =====================
Effects of Overexposure:INHAL:ANEST.IRRIT OF RESPIR TRACT OR ACUTE NERV
SYS DEPRESN,HDACH,DIZZ;STAGGERING GAIT,CONFUS,COMA.
======================= First Aid Measures =======================
First Aid:FUMES:REMOV FROM EXPO GET FRESH AIR.SPRAY EYES:FLUSH IMMED W
LG QTY OF RUNNING WATR F/AT LEAST 15 MIN.TAKE TO
DR.SPRAY(SKIN):WIPE OFF W/TOWEL.REMOV REMAIND W/MINERAL
SPIRITS,TURPENT OR LACQ THNNR,INCA SE OF LACQ.WASH
W/SOAP/WATR.REMOVE CONTAM CLOTH.
===================== Fire Fighting Measures =====================
Flash Point:-40F-40C
Lower Limits:0.8
Extinguishing Media:NFPA CL B EXTING LCO*2,DRY CHEM OR FOAM)F/A FLAMB
LIQD FIRE
Fire Fighting Procedures:WEAR GOGG & SELF-CONT BREATHING APP.
WATR.SPRAY MAY (SUP
Unusual Fire/Explosion Hazard:CNS WILL RPTR FR INTERNAL PRESSR AT ABOUT
190F & DISCHRG FLAMBL CONTNT.IF HEATD TO DECOMP,TOXIC FUM
================== Accidental Release Measures ==================
Spill Release Procedures:REMOV ALL SOURCES OF IGNIT (FLAMES,HOT
SURFACES & ELECTR; STATIC OR FRICTIONAL SPARKS).AVOID BREATHING
VAPORS.VENTILATE AREA.REMOVE W/INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F.STORE LG
QUANTITIES IN BLDGS DESIGNED & PROTECTED F/STORAGE OF NFPA CL IA
FLAMMABLE LIQUIDS.
Other Precautions:DO NOT SPRAY IN EYES.DO NOT PUNCTROR INCIN CNS.DO NOT
STICK PIN,NAIL OR ANYOTH SHARP OBJS INTO OPENING ON TOP OF CN.DO
NOT TAKEINTERN.AVD BREATHING OF VAP MIST.DO NOT FLAME CUT,BRAZE OR
(SUP)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CASUAL USE,NONE REQD,PROVIDE VENTILATION IS
AVAIL.
Ventilation:DILUTION OR EXHAUST TO KEEP BELOW TLV
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:42-391F
Vapor Density:HEAV
Evaporation Rate & Reference:PROPELL-FASTR,SOLV
Percent Volatiles by Volume:89
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:HYDROGEN CHLORIDE,CARBON
MONOXIDE,PHOSGENE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORD W/LOCAL, STATE & FEDERAL
REGULATION. INCINERATE IN APPROVED FACILITY. DO NOT INCINERATE
CLOSED CONTAINER.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:IMURAN
CAGE:5P291
CAGE:5P291
============= Composition/Information on Ingredients =============
Ingred Name:IMURAN
(6-((1-METHYL-4-NITRO-1H-IMIDAZOL-5-YL)THIO)-1H-PURINE OR
AZATHIOPRINE) * 50 MG AZATHIOPRINE ACTIVE INGREDIENT*
CAS:446-86-6
RTECS #:UO8925000
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL MOUSE) IS 2500 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:AZATHIOPRINE IS MUTAGENIC IN ANIMALS
AND HUMANS.THE PRINCIPAL EFFECT IS DEPRESSION OF THE BONE
MARROW.PROLONGED IMMUNOSUPRRESSION MAY RESULT IN SUPERINFECTION
WITH BACTERIA,VIRUSES,PROTOZOA AND FUNGI. AZATHIOPRINE HAS BEEN
SHOWN TO BE MUTAGENIC IN ANIMALS AND HUMANS.AZATHIOPRINE IS
TERATOGENIC IN RODENTS.
Explanation of Carcinogenicity:AZATHIOPRINE IS A CONFIRMED CARCINOGEN
BY IARC AND NTP.
Effects of Overexposure:MANUFACTURER DID NOT SPECIFY.
Medical Cond Aggravated by Exposure:NONE NOTED.
======================= First Aid Measures =======================
First Aid:EYES:RINSE IMMEDIATELY WITH PLENTY OF WATER.SEE DOCTOR.
SKIN:WASH OFF SKIN WITH PLENTY OF WATER.SEE DOCTOR IF CONTACT IS
PROLONGED. INHALATION:REMOVE TO FRESH AIR.SEE DOCTOR.
INGESTION:WASH OUT MOUTH. GIVE FLUIDS.SEE DOCTOR.THERE IS NOT A
SPECIFIC ANTIDOTE TO AZATHIOPRINE.A SINGLE MODERATE OVERDOSE IS NOT
SERIOUSLY THREATENING,BUT WOULD CALL FOR DAILY WATCH OF THE BLOOD
COUNT FOR AT LEAST 2 WEEKS.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SUITABLE PROTECTIVE CLOTHING.SWEEP UP
MINIMIZING DUST EVOLUTION.TRANSFER TO CLOSED DISPOSAL
CONTAINER.DECONTAMINATE AREA WITH DILUTE CAUSTIC SODA AND SODIUM
HYPOCHLORITE SOLUTION.CLEAN AREA WITH DETERGENT.
Neutralizing Agent:DILUTE CAUSTIC SODA AND SODIUM HYPOCHLORITE
SOLUTION.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE, HEAT AND IGNITION SOURCES. KEEP
CONTAINERS CLOSED. PROTECT FROM LIGHT.
Other Precautions:NONE NOTED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FULL AIR-SUPPLIED SUIT IS RECOMMENDED OR AN
AIR-SUPPLIED HOOD WITH FULL BODY COVERING.
Ventilation:LOCAL EXHAUST OR BIOLOGICAL SAFETY CABINET.
Other Protective Equipment:AVOID ALL CONTACT BY WEARING FULL BODY
PROTECTIVE CLOTHING (FOR EXAMPLE TYVEK).
Work Hygienic Practices:WASH THROUGHLY AFTER HANDLING AND BEFORE
EATING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
THIS IS AN ANTINEOPLASTIC DRUG. *CONTINUED FROM HEALTH HAZARDS:THERE
HAVE BEEN CLINICAL REPORTS OF STERILITY,AZOOSPERMIA AND TESTICULAR
ATROPHY IN MALE PATIENTS RECEIVING THIS DRUG*
================== Physical/Chemical Properties ==================
HCC:T6
Melt/Freeze Pt:M.P/F.P Text:460F,DECOMP
Solubility in Water:COMPLETE
Appearance and Odor:PALE,YELLOW,ODORLESS POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
INCOMPLETELY BURNED CARBON PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:NOTIFY YOUR LOCAL ENVIRONMENTAL OFFICER. DISPOSE
OF IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL LAWS
AND REGULATIONS. PRODUCT MAY BE INCINERATED. WASH WATERS AND RINSES
SHOULD BE DISCHA RGED TO AN APPROVED SEWERAGE SYSTEM.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:5922 AMINOPHYLLINE INJ USP
CAGE:60060
CAGE:60060
============= Composition/Information on Ingredients =============
Ingred Name:AMINOPHYLLINE DIHYDRATE
CAS:5877-66-5
RTECS #:XH5602000
Ingred Name:SODIUM CHLORIDE * 96-4 *
CAS:7647-14-5
RTECS #:VZ4725000
Ingred Name:AQUEOUS SOLUTION
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(MICE): 250-540 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SENSITIZATION TO ETHYLENEDIAMINE
OCCURS FOLLOWING EXPOSURE TO AMINOPHYLLINE. ETHYLENEDIAMINE IS A
POTENT SENSITIZER. AMINOPHYLLINE IS A DRUG THAT RELAXES SMOOTH
MUSCLE IN THE BRONCHIAL AIRWAYS & BLOOD VESSELS IN THE LUNGS. IS A
CORONARY VASODILATOR/CARDIAC STIMULANT, DIURETIC/CNS STIMULANT,
SKELETAL MUSCLE STIMULANT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NAUSEA, VOMITING W/BLOOD, GI DISTRESS,
DIARRHEA, HEADACHE, IRRITATBILITY, RESTLESSNESS, INSOMNIA,
PALPITATIONS, INCREASED HEART RATE, FLUSHING, LOWERED BLOOD
PRESSURE, INCREASED RESPIRATION, ALBUMINUR IA, INCREASED URINE
OUTPUT & RASHES.
Medical Cond Aggravated by Exposure:PRE-EXISTING SEVERE CARDIAC
DISEASE.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM SOURCE OF EXPOSURE. SKIN/EYES: FLUSH
W/COPIOUS AMOUNTS OF WATER. PROVIDE SYMPTOMATIC/SUPPORTIVE CARE,
MONITORING FLUIDS, BLOOD PRESSURE, BODY TEMPERATURE, RESPIRATION &
CONVULS IVE ACTIVITY, AS NECESSARY. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/SUITABLE MATERIAL, FLUSH W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Ventilation:NO SPECIAL PROVISIONS REQUIRED
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
pH:8.5-9
Solubility in Water:AQUEOUS SOLUTION
Appearance and Odor:CLEAR LIQUID
Percent Volatiles by Volume:<0.1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:LIGHT, HEAT
Hazardous Decomposition Products:TOXIC FUMES OF NITROGEN OXIDES
Conditions to Avoid Polymerization:LIGHT, HEAT
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF SOLUTION IN SEWER. BURY IN LANDFILL.
DISPOSE OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:SP SERIES SATIN POSTER SCREEN INK, SP-11
CAGE:JO110
CAGE:JO110
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC; (PETROLEUM
DISTILLATE VP:1,8 @ 20C
CAS:64742-88-7
Fraction by Wt: 45-55%
OSHA PEL:500 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:ETHANOL, 2-BUTOXY-; (2-BUTOXYETHANOL) VP:0.6 @ 20C
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: <5%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM
Ingred Name:PETROLEUM DISTILLATE (AROMATIC HYDROCARBON) <35 @ 68F
Fraction by Wt: <5%
OSHA PEL:500 PPM (MFR)
ACGIH TLV:N/K
Ingred Name:AROMATIC HYDROCARBON RESIN
Fraction by Wt: 5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHYL HYDROXYETHYL CELLULOSE
CAS:9004-58-4
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PLASTICIZER
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PIGMENTS (CONTAINING INGREDIENTS 8-12)
Fraction by Wt: 0-30%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:LEAD (II) SULFATE (1:1); (LEAD SULFATE) (SARA 313) (CERCLA)
CAS:7446-14-2
RTECS #:OG4375000
Fraction by Wt: 5-15%
OSHA PEL:SEE 1910.1025
ACGIH TLV:0.15 MG(PB)/M3
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:CHROMIC ACID, LEAD (2+) SALT (1:1); (LEAD CHROMATE)
CAS:7758-97-6
RTECS #:GB2975000
Fraction by Wt: 5-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:LEAD MOLYBDATE
CAS:10190-55-3
Fraction by Wt: 0-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:COPPER (SARA 313) (CERCLA)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 0-2%
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2 MG/M3 FUME
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:MANGANESE (SARA 313)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 0-5%
OSHA PEL:C 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST
Ingred Name:VOLATILE ORGANIC COMPOUND:540 G/L, 4.5 LB/GAL
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:CLEARLY DEMONSTRATED DOSE-RELATED ADVERSE EFTS ON
CNS, HEMATOPOIETIC TISS, BLOOD, KIDNEYS & LIVER, ASSOC (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:ADMIN OF ETHYLENE GLYCOL MONOBUTYL ETHER (EGBE)
(EXTRACTED FROM DHHS (NIOSH) PUBLICATION NO. 90-118) (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:. LEAD COMPOUNDS APPEAR ON NAVY LISTING OF OCCUP
CHEM REPRO HAZS. SEEK CONSULTATION FROM APPROP (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:HLTH PROFESSIONALS CONCERNING LATEST HAZ LIST INFO &
SAFE HNDLG & EXPOS INFO .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYE CONT W/LIQ, ITS VAPS/MISTS MAY
CAUSE BURNING, TEARING & REDNESS. SKIN CONT MAY CAUSE IRRIT. MATL
MAY BE ABSORBED THROUGH SKIN. INHAL MAY CAUSE RESP TRACT IRRIT/NERV
SYS DISORDERS SUCH AS HDCH, DIZ Z & FATG. INGEST MAY CAUSE GI TRACT
IRRIT & SIGNS OF NERV SYS DEPRESS. RPTD & PRLNGD OVEREXP BY INHAL,
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:LEAD CHROMATE:IARC MONOGRAPHS ON EVAL OF
CARCIN RISK OF CHEMS TO MAN, VOL 49, PG 49, 1990:GROUP 1. NTP 7TH
(SUPP DATA)
Effects of Overexposure:HLTH HAZS:SKIN ABSORP/INGEST MAY CAUSE DELAYED
DMG TO BLOOD, LIVER & KIDNEYS. RPTD & PRLNGD OVEREXP TO LEAD BY
INGEST MAY CAUSE METALLIC TASTE IN MOUTH, NAUS, DIGEST DISORDERS,
ABDOM CRAMPS & INSOMNIA AS WELL AS BLOOD, NERV, URINARY & REPRO
DISORDERS & BIRTH DEFECTS. RPTS HAVE ASSOC RPTD & PRLNGD OCCUP
OVEREXP (SUPDAT)
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN OR
LUNG DISORDERS MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THIS
MATERIAL.
======================= First Aid Measures =======================
First Aid:SKIN:WASH WITH SOAP AND WATER, CONTACT PHYSICIAN IF
IRRITATION PERSISTS. EYES:FLUSH WELL WITH RUNNING WATER FOR AT
LEAST 15 MINUTES, CONTACT PHYSICIAN IF IRRITATION PERSISTS.
INHALATION:REMOVE TO FRES H AIR, RESTORE BREATHING, CONTACT
PHYSICIAN. INGESTION:CONTACT PHYSICIAN OR POISON CONTROL CENTER
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:104F,40C
Lower Limits:0.7%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . WATER MAY BE INEFFECTIVE BUT MAY BE USED TO
COOL CONTAINERS.
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT,
SPARKS AND OPEN FLAME. CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED
TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE
AREA. AVOID BREATHING VAPORS. CONTAIN RELEASE AND REMOVE WITH INERT
ABSORBENT. AVOID CONTACT. USE NON-SPARKING TOOLS TO PLACE MATERIAL
IN APPROPRIATE CONTAINE R FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS IN COOL,
DRY, WELL VENTILATED AREA AWAY FROM SOURCE OF IGNITION. KEEP
CONTAINERS CLOSED WHEN NOT IN USE.
Other Precautions:AVOID PROLONGED OR REPEATED OVEREXPOSURE TO THIS
PRODUCT. EMPTY CONTAINERS SHOULD BE DISPOSED OF IN AN
ENVIRONMENTALLY SAFE MANNER IN ACCORDANCE WITH APPLICABLE
REGULATIONS. REMOVE CONTAMINATED CLOTHI NG TO PREVENT PROLONGED
SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VAPOR CONCENTRATION EXCEEDS THE TLV LISTED IN
INGREDIENTS, USE NIOSH/MSHA APPROVED RESPIRATOR WITH ORGANIC
CHEMICAL CARTRIDGE. CONTACT A REPUTABLE SAFETY SUPPLY COMPANY FOR
THE APPROPRIATE RESPIRAT OR.
Ventilation:AS REQUIRED TO KEEP THE VAPOR CONCENTRATION BELOW THE TLV
LISTED IN INGREDIENTS.
Other Protective Equipment:SOLVENT RESISTANT APRONS. EMERG EYE WASH AND
DELUGE SHOWER WHICH MEET ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH WITH SOAP AND WATER BEFORE EATING,
SMKING/USING TOILET FACILITIES. SMOKE IN DESIGNATED AREAS ONLY.
Supplemental Safety and Health
EXPLAN OF CARCIN:ANNUAL RPT ON CARCINS, 1994:KNOWN TO BE CARCIN. PROT
BRAIN & NERV SYS DMG. INTENTIONAL MISUSE BY DELIB CONC & INHAL
CONTENTS MAY BE HARMFUL/FATAL. ANIMAL STUDIES (ING 14)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:70
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
OTHER NOXIOUS GASES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL,
COUNTRY, STATE AND FEDERAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:1751B ALUMINUM EPOXY ADHESIVE
Kit Part:Y
Preparer's Name:C A EISENHARD
CAGE:76381
CAGE:04963
CAGE:76381
============= Composition/Information on Ingredients =============
Ingred Name:BISPHENOL A DIGLYCIDYL ETHER RESIN, EPOXY RESIN, EPON 820,
ARALDITE 6004, AMINE ADDUCT, ARALDITE GY250 *96-3*
CAS:25068-38-6
RTECS #:KD4380000
Fraction by Wt: 40-50%
Ingred Name:ALUMINUM*96-3*
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 30-40%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:QUATERNARY AMMONIUM COMPOUNDS, BIS(HYDROGENATED TALLOW
ALKYL) DIMETHYLAMMONIUM BENTONITE *96-3*
CAS:68953-58-2
RTECS #:UZ2996400
Fraction by Wt: 1-10%
Ingred Name:N-BUTYL GLYCIDYL ETHER
CAS:2426-08-6
RTECS #:TX4200000
Fraction by Wt: 1-10%
Other REC Limits:25 PPM
OSHA PEL:270 MG/CUM
ACGIH TLV:133 MG/CUM
Ingred Name:AMORPHOUS SILICA GEL *96-3*
CAS:7631-86-9
Fraction by Wt: 1-10%
Ingred Name:RESORCINOL, M-DIHYDROXYBENZENE
CAS:108-46-3
RTECS #:UG9625000
Fraction by Wt: 1-10%
Other REC Limits:10 PPM
ACGIH TLV:45 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATING. SKIN: IRRITATING,
SENSITIZATION. INHALATION: IRRITATING TO NOSE & THROAT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR 10 MINS. SKIN: WASH
THOROUGHLY W/SOAP & WATER. INHALATION: REMOVE PERSON TO FRESH AIR.
INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, FOAM, DRY CHEMICALS, WATER.
Fire Fighting Procedures:WEAR SCBA.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. COLLECT & DISPOSE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Ventilation:USE ONLY W/SUFFICIENT VENTILATION TO MAINTAIN VAPOR
CONCENTRATIONS BELOW EXPOSURE LIMITS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:1.3
Solubility in Water:SLIGHT
Appearance and Odor:GRAY VISCOUS PAINT W/LITTLE ODOR
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:THERMAL/BURNING: CARBON, HYDROGEN,
NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MOBILARMA 552
CAGE:6G112
CAGE:6G112
============= Composition/Information on Ingredients =============
Ingred Name:REFINED MINERAL OILS
Fraction by Wt: >90.0%
Other REC Limits:5MG/CUM AS OIL MIST
Ingred Name:ADDITIVES AND/OR OTHER INGREDS
Fraction by Wt: <10.0%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RAT:5G/KG
Routes of Entry: Inhalation:UNKNOWN Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:ACUTE:SLIGHT IRRITATION OF EYES AND
SKIN. CHRONIC:NO DATA AVAILABLE.
Effects of Overexposure:SLIGHT IRRITATION OF EYES AND SKIN.
Medical Cond Aggravated by Exposure:NO DATA AVAILABLE.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH WATER;CALL A PHYSICIAN IF NEEDED. SKIN:WASH
WITH SOAP AND WATER. INGESTION:DO NOT INDUCE VOMITING;SEEK MEDICAL
HELP.
===================== Fire Fighting Measures =====================
Flash Point Method:OC
Flash Point:>360F/182C
Lower Limits:0.6
Upper Limits:7.0
Extinguishing Media:FOAM,DRY CHEMICAL AND WATER FOG
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA IN AN ENCLOSED
AREA.
Unusual Fire/Explosion Hazard:NONE NOTED.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;USE SUITABLE
ABSORBENT AND RECOVER FOR PROPER DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY AND WELL VENTILATED
AREA. KEEP AWAY FROM HEAT,OPEN FLAMES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NEEDED IN ADEQUATE VENTILATION.
Ventilation:GENERAL TO MAINTAIN ADEQUATE VENTILATION.
Other Protective Equipment:FULL SKIN AND EYES PROTECTION.
Work Hygienic Practices:AVOID CONTACT WITH SKIN AND EYES; DO NOT
BREATHE VAPORS/MIST.
Supplemental Safety and Health
MSDS IS FROM CONSOLIDATED CONTROLS CORP.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:>600F/316C
Vapor Pres:<0.1
Spec Gravity:0.86
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIQUID,MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:EXTREME HEAT
Hazardous Decomposition Products:CO OR CO*2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF COLLECTED MATERIAL IN ACCORDANCE WITH
LOCAL,STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:WATER REMOVABLE FILM INK BLUE LIQUID
CAGE:17405
CAGE:17405
============= Composition/Information on Ingredients =============
Ingred Name:ACID DYE
Fraction by Wt: 1-8%
Ingred Name:FORMALDEHYDE (SARA III)
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: <1%
Other REC Limits:A2 CARCINOGEN
OSHA PEL:SEE 1910.1048
ACGIH TLV:C 0.3 PPM; A2; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:N-PROPYL ALCOHOL
CAS:71-23-8
RTECS #:UH8225000
Fraction by Wt: <8%
Other REC Limits:200 PPM
OSHA PEL:200 PPM/250 STEL
ACGIH TLV:S,200PPM/250STEL9192
Ingred Name:GLYCOL ETHERS, DIETHYLENE GLYCOL
CAS:111-46-6
RTECS #:ID5950000
Fraction by Wt: <5%
ACGIH TLV:5 PPM
Ingred Name:NON-IONIC SURFACTANT
Fraction by Wt: <0.5%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RATS LD50: 1.9 ML/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION. INHALATION:
RESPIRATORY IRRITATION. INGESTION: GASTRIC DISTURBANCE.
Explanation of Carcinogenicity:ALL COLORS CONTAIN DYES WHICH ARE
SUSPECTED CARCINOGENS. FORMALDEHYDE IS A POSITIVE ANIMAL/INDEFINITE
HUMAN CARCINOGEN.
Effects of Overexposure:EYES/SKIN: IRRITATION. INHALATION: RESPIRATORY
IRRITATION. INGESTION: GASTRIC DISTURBANCE.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH THOROUGHLY W/WATER. INHALATION: REMOVE TO
FRESH AIR. GIVE CPR OR OXYGEN IF NEEDED. INGESTION: INDUCE
VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:OC
Flash Point:189F
Extinguishing Media:USE MEDIA PROPER TO PRIMARY CAUSE OF FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
TURN-OUT GEAR.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP SPILLS W/TOWELS & CLOTHS. REMOVE
STAINS W/SOAPY WATER.
Neutralizing Agent:WATER
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT W/SKIN & EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:APPROVED ORGANIC VAPOR REPIRATOR, IF VAPORS OR
MISTS ARE GENERATED.
Ventilation:MECHANICAL: RECOMMENDED
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:205-550F
Spec Gravity:1.005-1.035
Solubility in Water:COMPLETE
Appearance and Odor:COLORED LIQUID W/FORMALDEHYDE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:TEMPS. >554F.
Hazardous Decomposition Products:ACROLEIN
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TITANIUM CP & 6-4
CAGE:FO284
CAGE:FO284
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM (DRY POWDER)
CAS:7440-32-6
RTECS #:XR1700000
Fraction by Wt: 46-99%
Ingred Name:ALUMINUM (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 6%
OSHA PEL:15MG/M3 DUST/5 FUME
ACGIH TLV:10MG/M3 DUST; 9192
Ingred Name:VANADIUM (SARA III)
CAS:7440-62-2
RTECS #:YW1355000
Fraction by Wt: 10%
Other REC Limits:0.1 MG/CUM
OSHA PEL:C,0.5 MG V2O5/M3 RD
ACGIH TLV:0.05 MG V205/M3;9293
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: 48%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
Fraction by Wt: 6%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9293
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
Fraction by Wt: 5%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9192
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 4%
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:TANTALUM
CAS:7440-25-7
RTECS #:WW5505000
Fraction by Wt: <1%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3; DUST; 9192
Ingred Name:CHROMIUM ION (CR 3+)
CAS:16065-83-1
RTECS #:GB6261000
Fraction by Wt: 2-6%
OSHA PEL:0.5 MG/M3 (CR)
ACGIH TLV:0.5 MG/M3 (CR); 8990
Ingred Name:COPPER (SARA III)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 2-2.5%
Other REC Limits:0.2 MG/CUM FUMES
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2MG/M3 FUME; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: .8%
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
Ingred Name:ZIRCONIUM
CAS:7440-67-7
RTECS #:ZH7070000
Fraction by Wt: 4%
OSHA PEL:5 MG/M3/10 STEL
ACGIH TLV:5 MG/M3/10 STEL;9192
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF THE THROAT,
EYES, & INFLUENZA-LIKE SYMPTOMS & DRYNESS, SENSITIZATION
DERMATITUS, INFLAMMATION. SKIN: PHYSICAL ABRASION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: IRRITATION OF THE THROAT, EYES, &
INFLUENZA-LIKE SYMPTOMS & DRYNESS, SENSITIZATION DERMATITUS
INFLAMMATION, ULCERATION OF UPPER RESPIRATORY TRACT & POSSIBLE
CANCER OF NASAL PASSAGES & LUNG S.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR, SEEK MEDICAL AID
IMMEDIATELY. EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL POWDERS, SALTS OR INERT GAS. DO NOT
USE WATER OR LIQUID: EXPLOSION HAZARD COULD RESULT.
Fire Fighting Procedures:STORE WET & KEEP AWAY FROM HEAT & OPEN FLAME -
MAINTAIN HUMIDITY >50% TO PREVENT AN ELECTROSTATIC BUILD-UP.
Unusual Fire/Explosion Hazard:THIS PRODUCT DOESN'T BURN, HOWEVER,
GRINDING OR POLISHING THIS PRODUCT IN THE ABSENCE OF OXYGEN, SUCH
AS UNDER WATER, CAN RESULT IN A FINELY DIVIDED WASTE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP WORK AREAS FREE OF THE WASTE.
STORE WET/KEEP AWAY FROM HEAT/OPEN FLAME-MAINTAIN HUMIDITY >50% TO
PREVENT AN ELECTROSTATIC BUILD-UP. .
Other Precautions:USE NON-SPARKING METAL EQUIPMENT. DRY CHEMICAL
POWDERS, SALTS OR INERT GAS. DON'T USE WATER OR LIQUID: EXPLOSION
HAZARD COULD RESULT. NO SMOKING NO AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA - APPROVED DUST & FUME RESPIRATOR.
Ventilation:PROVIDE LOCAL EXHAUST VENTILATION TO KEEP <TLV.
Work Hygienic Practices:NO SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:1560-1840C
Solubility in Water:SOLID
Appearance and Odor:GRAY METALLIC, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, OPEN FLAME
Hazardous Decomposition Products:METALLIC DUST OR FUMES MAY BE PRODUCED
DURING WELDING, BURNING, GRINDING & POSSIBLY MACHINING.
==================== Disposal Considerations ====================
Waste Disposal Methods:ACCORDING TO LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CLIPPERCIDE
CAGE:50898
CAGE:50898
============= Composition/Information on Ingredients =============
Ingred Name:2-BIPHENYLOL; (O-PHENYL PHENOL) (SARA 313)
CAS:90-43-7
RTECS #:DV5775000
Fraction by Wt: 0.41%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ISOPROPYL ALCOHOL (SARA 313)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 45.63%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM;500 STEL
Ingred Name:PROPANE, 2-METHYL-; (ISOBUTANE). MFR'S INVALID CAS
NO:72-28-5.
CAS:75-28-5
RTECS #:TZ4300000
OSHA PEL:800 PPM (MFR)
ACGIH TLV:800 PPM (MFR)
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:VAPOR MAY IRRITATE EYES, NOSE AND
THROAT.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:DIZZINESS.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . EYES:FLUSH THOROUGHLY W/WATER
FOR AT LEAST 15 MINUTES. SKIN:WASH W/MILD SOAP & WATER.
INHAL:REMOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Lower Limits:14.8%
Upper Limits:22%
Extinguishing Media:DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . COOL CANS TO PREVENT POSSIBLE BURSTING. DO NOT EXPOSE
TO HEAT OR STORE AT TEMPERATURES >130F (54C).
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILLS:MOP OR WIPE UP. LARGE
SPILLS:VENTILATE AREA. CONTAIN LIQUID & TRANSFER TO STEEL DRUMS.
CAP TIGHTLY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY AREA. DO NOT
PUNCTURE OR INCINERATE CANS.
Other Precautions:FLAMMABLE GAS. READ LABEL PRECAUTIONS THOROUGHLY
BEFORE USE. AVOID SPRAYING ON SKIN OR EYES. KEEP OUT OF REACH OF
CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Vapor Density:HVR/AIR
Solubility in Water:PARTIALLY SOLUBLE
Appearance and Odor:AEROSOL SPRAY; LIGHT PLEASANT FRAGRANCE.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:OPEN FLAME OR HIGH HEAT.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FLAW-FINDER AG-RH CLEANER(POST 3/90)
Kit Part:Y
Preparer's Name:GEORGE KOSEL,CHIEF CHEM
CAGE:03530
CAGE:03530
============= Composition/Information on Ingredients =============
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 96.0%
Other REC Limits:NONE SPECIFIED
OSHA PEL:350 PPM/450 STEL
ACGIH TLV:350 PPM/450STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:CHLORODIFLUOROMETHANE
CAS:75-45-6
RTECS #:PA6390000
Fraction by Wt: 4.0%
OSHA PEL:1000 PPM
ACGIH TLV:1000PPM; 9192
Ozone Depleting Chemical:2
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRITATION OF EYES, SKIN,
RESPIRATORY TRACT; HEADACHE, DIZZINESS, ANESTHETIC EFFECTS, CNS
DEPRESSION; CHRONIC: DEFATTING, DERMATITIS; HEALTH STUDIES HAVE
SHOWN THAT MANY HALOGENATED HYDROCARBON S POSE POTENTIAL HUMAN
HEALTH RISKS WHICH MAY VARY FROM PERSON TO PERSON.
Explanation of Carcinogenicity:MFRG STATED THAT 1,1,1-TRICHLOROETHANE
HAS BEEN SUBJECTED TO A CARCINOGENESIS BIOASSAY BY NCI AND FOUND
NOT A CARCINOGEN
Effects of Overexposure:INHALATION:HIGH VAPOR CONC CAUSES
IRRITATION,HEADACHE,DIZZINESS AND CNS
DEPRESSION;SKIN:PROLONGED/REPEATED CONTACT TENDS TO REMOVE SKIN OIL
POSSIBLY LEADING TO IRRITATION AND DERMATITIS;EYES:LIQ CONTA CT MAY
CAUSE IRRITATION;INGESTION:PRODUCT HAS LOW ORDER OF ACUTE ORAL
TOXICITY.MINUTE QTY INSPIRATED IN LUNGS IS FATAL.
Medical Cond Aggravated by Exposure:NONE REPORTED BY THE MANUFACTURER.
HOWEVER, PRE-EXISTING CONDITIONS MAY BE WORSEN.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR: SEEK MEDICAL HELP. IF
BREATHING IS IRREGULAR OR HAS STOPPED, START RESUSCITATION AND
ADMINISTER OXYGEN IF AVAILABLE; SKIN AND EYES: FLUSH WITH PLENTY OF
WATER FOR ABOU T 15 MINUTES. SEEK MEDICAL HELP IF IRRITATION
PERSISTS. INGESTION: DO NOT INDUCE VOMITING. IMMEDIATELY CALL A
PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:7.5
Upper Limits:15.0
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY. CONTAIN RUNOFF.
Unusual Fire/Explosion Hazard:NONE CURRENTLY KNOWN.COMBUSTION OR HEAT
OF FIRE MAY PRODUCE HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION: REMOVE ALL
IGNITION SOURCES: RECOVER FREE LIQUID; USE SUITABLE INERT ABSORBENT
MATERIAL SUCH AS SAND, SAWDUST, ETC.. TO ABSORB SPILLED LIQUID.
VENTILATE CONFINED SPACES .KEEP MATERIAL OUT OF SEWERS AND WATER
COURSES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL DRY PLACE BELOW 120F.
DO NOT PUNCTURE OR INCINERATE AEROSOL CANS. DO NOT STORE OR HANDLE
NEAR HEAT, SPARKS OR OXIDANTS.
Other Precautions:DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL,
GRIND,OR EXPOSE SUCH CONTAINERS TO HEAT, FLAME, SPARKS OR OTHER
SOURCES OF IGNITION:THEY MAY EXPLODE AND CAUSE INJURY OR DEATH.DO
NOT ATTEMPT TO CLE AN SINCE RESIDUE IS DIFFICULT TO REMOVE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE SUPPLIED-AIR RESPIRATOR PROTECTION IN
CONFINED AREA, IF NEEDED.
Ventilation:PROVIDE >60FPM HOOD FACE VELOCITY. LOCAL EXHAUST TO
MAINTAIN PEL/TLV (USE EXPLOSION PROOF EQUIPMENT.)
Other Protective Equipment:USE CHEMICAL RESISTANT APRON OR OTHER
IMPERVIOUS CLOTHING, IF NEEDED, TO AVOID CONTAMINATING REGULAR
CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY AFTER EACH USE.
Supplemental Safety and Health
AG-RH CLEANER IS CLASS 1 REMOVER OF MIL-I-25135. PER MFRG, PROPELLANT
HAS BEEN SWITCHED FROM CARBON DIOXIDE TO FREON 22 EFFECTIVE MARCH
90. PER MIL-I-25135,REV E AND QPL-25135-14/15,THIS REMOVER,AG-RH
,IS QUALIFIED WITH FORM-D DEVELOPER ANDTY I,METH C,LEVEL 3
PENETRANT. SEE PNIND C FOR OLD CLEANER PROPELLANT. KEY1:J7
================== Physical/Chemical Properties ==================
HCC:V2
Boiling Pt:B.P. Text:162F,72C
Vapor Pres:100MMHG@20
Vapor Density:4.55
Spec Gravity:1.32 (BULK)
Evaporation Rate & Reference:1.33 (WATER=1) (BULK)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS LIQUID; SWEET ODOR
Percent Volatiles by Volume:>99%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENT, STRONG CAUSTICS, REACTIVE METALS LIKE ALUMINUM.
Stability Condition to Avoid:EXTREMELY HIGH TEMPERATURES
Hazardous Decomposition Products:HYDROGEN CHLORIDE, SMALL AMOUNT OF
PHOSGENE AND CHLORINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF RECOVERED MATERIAL AT AN APPROVED
DISPOSAL SITE OR FACILITY. CAN BE RECLAIMED AND RECYCLED. ASSURE
CONFORMITY WITH ALL APPLICABLE LOCAL, STATE AND FEDERAL DISPOSAL
REGULATIONS. DO NOT INCIN ERATE EMPTY OR PARTIALLY FILLED
AEROSOLCANS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:3-1014, BLACK OFFSET INK
Preparer's Name:KENNETH W. PINTER
CAGE:HO951
CAGE:17638
CAGE:HO951
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: <3%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9293
Ingred Name:TREATED PETROLEUM OILS
Fraction by Wt: >1%
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: MAY CAUSE IRRITATION. SKIN: NOT A
SKIN IRRITANT UNDER NORMAL USE. SENSITIVE INDIVIDUALS MAY DEVELOP
DERMATITIS. INHAL: NORMALLY NOT A PROBLEM WITH THIS MATERIAL.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:MAY CAUSE EYE IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST: DRINK 1 OR 2 GLASSES OF WATER TO DILUTE. DO NOT
INDUCE VOMIT. CALL PHYS. TREAT SYMTOMATICALLY. EYE: FLUSH IMMED
WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15 MIN. CALL PHYS IF IRRIT
OCCURS. SKIN : WASH AFFECTED AREAS WITH SOAP AND WATER. REMOVE
CONTAMINATED CLOTHING. INHAL: REMOVE TO FRESH AIR. SUPPORT BRTHG.
(GIVE O2/ARTF RESP) .
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>250F,>121C
Lower Limits:1%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:DURING EMERGENCY CONDITIONS, OVEREXPOSURE
TO COMBUSTION PRODUCTS MAY CAUSE HEALTH HAZARDS.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP AND DISPOSE OF WITH SOLID WASTE. IF
SOLVENT WETTED WIPES WERE USED, DISPOSE OF IN APPROVED CONTAINERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE. KEEP AWAY FROM HEAT OR OPEN FLAME.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED WITH ADEQUATE VENTILATION.
USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF
CONCERN .
Ventilation:MECHANICAL(GENERAL): ACCEPTABLE.
Other Protective Equipment:NONE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>520F,>271C
Vapor Density:>1(AIR=1)
Spec Gravity:1.12
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK/HYDROCARBON
Percent Volatiles by Volume:20
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:CO, CO2, SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS FOR NON-FLAMMABLE OILY WASTE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:4660 CHO-BOND
Preparer's Name:DAVID HAAS
CAGE:GO416
CAGE:GO416
CAGE:18565
============= Composition/Information on Ingredients =============
Ingred Name:SILVER
CAS:7440-22-4
RTECS #:VW3500000
Fraction by Wt: 60-70%
OSHA PEL:0.01 MG/CUM
ACGIH TLV:0.1 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:COPPER (DUST & MIST), BRONZE POWDER
CAS:7440-50-8
RTECS #:GL5325000
Other REC Limits:1 MG(CU)/M3 (DUST)
OSHA PEL:0.1 MG(CU)/M3 (FUME)
ACGIH TLV:0.2 MG/M3 (FUME)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:POLYISOBUTYLENE
CAS:9003-27-4
RTECS #:UD1010000
Fraction by Wt: 10-20%
Ingred Name:HEPTANE
CAS:142-82-5
RTECS #:MI7700000
Fraction by Wt: 10-20%
Other REC Limits:400 PPM
OSHA PEL:2000 MG/CUM
ACGIH TLV:1640 MG/CUM
Ingred Name:SILICON DIOXIDE, CELITE 322
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: <2%
OSHA PEL:80 MG/CUM
ACGIH TLV:0.2 MG/CUM
Ingred Name:COLUMBIA CARBON, CARBON BLACK, LAMPBLACK, BLACK PEARLS
(IARC CARC GROUP 3) - *95-2*
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: <2%
Other REC Limits:3.5 MG/CUM (NIOSH)
OSHA PEL:3.5 MG/CUM
ACGIH TLV:3.5 MG/CUM
Ingred Name:EPICHLOROHYDRIN, CHLOROMETHYLOXIRANE (ANIMAL CARCINOGEN BY
IARC - GROUP 2A; SUSPECTED CARCINOGEN BY NTP) *95-2*
CAS:106-89-8
RTECS #:TX4900000
Fraction by Wt: <0.01%
Other REC Limits:2 PPM
OSHA PEL:5 PPM (SKIN) TWA
ACGIH TLV:0.38 MG/CUM IC (A2)
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATON. SKIN:
IRRITATION & DERMATITIS. INHALATION: HIGH VAPOR CONCENTRATIONS MAY
CAUSE RESPIRATORY IRRITATION & MAY CAUSE ANESTHETIC EFFECTS/OTHER
TEMPORARY CENTRAL NERVOUS SYSTEM EFFE CTS. EXCESSIVE/PROLONGED
CONTACT W/SILVER/SILVER COMPOUNDS HAS BEEN KNOWN TO CAUSE ARGYRIA,
A BLUE-GRAY DISCOLORATION.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, DEFATTING, DRYNESS, HEADACHES,
NAUSEA, DIZZINESS.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH THOROUGHLY W/WATER FOR 15 MINS. SKIN:
FLUSH AREA THOROUGHLY W/PLENTY OF WATER. FOLLOW BY WASHING W/SOAP &
WATER. INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN/CPR IF NEEDED.
ING ESTION: DON'T INDUCE VOMITING. IF CONSCIOUS & ALERT, DILUTE BY
GIVING WATER TO DRINK; NEVER GIVE ANYTHING BY MOUTH TO A DROWSY,
UNCONSCIOUS/CONVULSING PERSON. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point:18F (HEPTANE)
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:WEAR POSITIVE PRESSURE SCBA & FULL PROTECTIVE
EQUIPMENT. COOL EXPOSED CONTAINERS W/WATER TO PREVENT PRESSURE
BUILDUP. EVACUATE AREA & FIGHT FIRE FROM A DISTANCE
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY VIOLENTLY RUPTURE
UNDER FIRE CONDITIONS. VAPORS ARE HEAVIER THAN AIR & MAY TRAVEL TO
DISTANT SOURCE OF IGNITION & FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: WIPE UP/ABSORB W/VERMICULITE/OTHER
MATERIAL. WASH AREA W/SOAPY WATER TO REMOVE RESIDUE. COLLECT
ABSORBED MATERIAL & WATER RINSE IN APPROPRIATE CHEMICAL WASTE
CONTAINERS. LARGE: EVACUATE PERSONN EL & CLEANUP IMMEDIATE AREA.
(SEE SUPP)
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY LOCATION
W/ADEQUATE VENTILATION. KEEP CONTAINER TIGHTLY SEALED WHEN NOT IN
USE. DON'T STORE NEAR HEAT, SPARKS/OPEN FLAME.
Other Precautions:EMPTY CONTAINER MAY CONTAIN FLAMMABLE LIQUID/VAPOR
RESIDUE. DON'T CUT, WELD, SOLDER, DRILL, GRIND/EXPOSE CONTAINER TO
HEAT, FLAME/OTHER SOURCE OF IGNITION. THEY MAY EXLODE & CAUSE
INJURY/DEATH.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE AN APPROPRIATE, PROPERLY FITTED RESPIRATOR
IF EXPOSURES EXCEED PEL/TLV VALUES.
Ventilation:EXPLOSION PROOF MECHANICAL EXHAUST: SUFFICIENT TO MAINTAIN
AIRBORNE CONCENTRATIONS < THEIR PEL/TLV VALUES.
Other Protective Equipment:CHEMICAL RESISTANT APRON & IMPERVIOUS
CLOTHING, EYE WASH FACILITIES & SAFETY SHOWER.
Supplemental Safety and Health
WASH HANDS & FACE THOROUGHLY AFTER HANDLING & BEFORE
EATING/DRINKING/SMOKING. LARGE SPILL CONT'D: SHUT OFF SOURCE OF
RELEASE W/O RISK OF INJURY. DIKE AREA TO CONTAIN & PREVENT RELEASES
TO SEWERS/OTHER WATERWAYS. COLLECT MATERIAL FOR SALVALGE/DISPOSAL.
PREVENT RUNOFF FROM ENTERING SEWER/OTHER WATERWAYS. B.P: HEPTANE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text: 700F (SUPP
Vapor Pres:8
Vapor Density:>1
Spec Gravity:>1.5
Solubility in Water:INSOLUBLE
Appearance and Odor:GRAY-SILVER LIQUID W/SOLVENT ODOR
Percent Volatiles by Volume:<20W/T
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS, BASES.
Stability Condition to Avoid:OPEN FLAME, HEAT, SPARKS/OTHER SOURCES OF
IGNITION.
Hazardous Decomposition Products:CO, CO2, ALDEHYDES, ACIDS & OTHER
ORGANIC SUBSTANCES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AS AN IGNITABLE WASTE IAW/FEDERAL,
STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:NORCAST A4000 PART B
Kit Part:Y
CAGE:33530
CAGE:33530
============= Composition/Information on Ingredients =============
Ingred Name:AMINOPROPYLTRIETHOXYSILANE OR GAMMA AMINO PROPYL TRIETHOXY
SILANE
Fraction by Wt: 100%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE IRRITATION. AVOID CONTACT
WITH SKIN, EYES, CLOTHING. EYE CONTACT CAUSES SEVERE IRRITATION &
MAY DAMAGE TISSUE. SKIN CONTACT MAY CAUSE MILD IRRITATION.
INGESTION MAY PRODUCE ABDOMINAL PAIN. I NHALATION CAUSES MILD
RESPIRATORY IRRITATION.
Explanation of Carcinogenicity:NONE OF THE INGREDIENTS IN THIS PRODUCT
IS LISTED BY NTP, IARC OR OSHA AS A CARCINOGEN.
Effects of Overexposure:INHALED- MILD RESPIRATORY IRRITATION.
SKIN-IRRITATION. EYES-SEVERE IRRITATION, DAMAGE EYE TISSUE.
INGESTION-ABDOMINAL PAIN.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES-FLUSH WITH WATER FOR 15 MINUTES, HOLD LIDS OPEN. GET
MEDICAL ATTENTION. SKIN-WASH WITH SOAP & WATER. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. INHALED-REMOVE TO FRESH AIR. RESTORE
BREATHING AS N EEDED. GET MEDICAL ATTENTION. INGESTED-INDUCTION OF
VOMITING DETERMINED BY MEDICAL PROFESSIONALS ONLY! IF CONSCIOUS,
GIVE SEVERAL GLASSES WATER. SEEK IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:220F,104C
Extinguishing Media:USE SODIUM CHLORIDE, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL. DO NOT USE WATER BECAUSE OF REACTION.
Fire Fighting Procedures:EVACUATE NON-ESSENTIAL PERSONNEL. WEAR
IMPERVIOUS CLOTHING AND A FULL FACED SELF CONTAINED BREATHING
APPARATUS.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
SOAK UP LIQUID WITH SUITABLE ABSORBENT SUCH AS SAWDUST, CLAY OR OIL
ABSORBER. SWEEP UP ABSORBED MATERIAL & PLACE IN A CHEMICAL WASTE
DRUM FOR SALVAGE OR DISP OSAL. WASH AREA WITH WATER & DETERGENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH SKIN & EYES. USE IN
A WELL-VENTILATED AREA.
Other Precautions:PEOPLE USING CONTACT LENSES SHOULD TAKE EXTRA
PRECAUTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:THE MATERIAL SHOULD BE HANDLED IN AN OPEN OR
WELL-VENTILATED AREA/MECHANICAL VENTIALTION.WHERE ADEQUATE
VENTILATION IS NOT AVAILABLE,USE NIOSH-APPROVED ORGANIC VAPOR
RESPIRATOR.WHERE EXPOSURE NECCESIT ATES,POSITIVE PRESSURE SCBA
RECOMMENDED.
Ventilation:GOOD MECHANICAL VENTILATION IS SUGGESTED IN A CLOSED
AREA.(DLA-HMIS: EXPLOSION-PROOF).
Other Protective Equipment:PROTECTIVE APRON OR COVERALLS. EYE WASH
STATION.
Work Hygienic Practices:USE GOOD HYGENIC PRACTICES.
Supplemental Safety and Health
KEY1:N1. THIS IS PART B OF A 2-PART PRODUCT. FOR PART A, SEE PNI C,
SAME NSN.
================== Physical/Chemical Properties ==================
HCC:V5
Boiling Pt:B.P. Text:423F,217C
Vapor Pres:10
Spec Gravity:0.943
Viscosity:1 CPS
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:REACTS
Appearance and Odor:COLORLESS LIQUID. AMINO ODOR.
Percent Volatiles by Volume:<1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONTACT WITH ACIDIC, BASIC OR OXIDIZING AGENTS.
Stability Condition to Avoid:KEEP AWAY FROM CONTACT WITH WATER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
SILICONE DIOXIDE, ETHANOL.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:MATERIAL THAT CANNOT BE USED SHOULD BE DISPOSED
OF IN AN EPA AUTHORIZED FACILITY. DISPOSE OF EMPTY CONTAINERS
ACCORDING TO ANY APPLICABLE REGULATIONS UNDER RCRA.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PP-340 AROCLOR SOLUTION AT 100 UG/ML IN METHANOL
CAGE:0MU35
CAGE:0MU35
============= Composition/Information on Ingredients =============
Ingred Name:METHANOL (METHYL ALCOHOL), COLUMBIAN SPIRITS
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 99.99%
Other REC Limits:200 PPM
OSHA PEL:260 MG/CUM
ACGIH TLV:262 MG/CUM (SKIN)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:POLYCHLORINATED BIPHEYNL, PCB, AROCLOR 1248, (CL 48%)
CAS:12672-29-6
RTECS #:TQ1358000
Fraction by Wt: 0.013%
Other REC Limits:0.001 MG/CUM NIOSH
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 12900 MG/KG METHANOL
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TOXIC; IRRITANT.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/PLENTY OF WATER. INHALATION: REMOVE TO
FRESH AIR. GIVE OXYGEN IF NECESSARY. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:COMBUSTIBLE
Extinguishing Media:CO2, DRY CHEMICAL POWDER, OR WATER SPRAY
================== Accidental Release Measures ==================
Spill Release Procedures:SHOULD NOT POSE A SIGNIFICANT PROBLEM. A
LEAKING BOTTLE MAY BE PLACED IN A PLASTIC BAG & NORMAL DISPOSAL
PROCEDURES FOLLOWED. LIQUID SAMPLES MAY BE ABSORBED ON VERMICULITE
OR SAND.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP TIGHTLY CLOSED. STORE IN A COOL,
DRY PLACE.
Other Precautions:AVOID CONCTACT W/EYES, SKIN & CLOTHING. THIS MATERIAL
SHOULD ONLY BE USED BY THOSE PERSONS TRAINED IN THE SAFE HANDLING
OF HAZARDOUS CHEMICALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE AN APPROPRIATE OSHA/MSMA APPROVED SAFETY
RESPIRATOR.
Other Protective Equipment:LAB COAT &/OR RUBBER APRON
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Appearance and Odor:LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED W/AN
AFTERBURNER & SCRUBBER. OBSERVE ALL FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:C6363-2-10
CAGE:01277
CAGE:01277
CAGE:82647
============= Composition/Information on Ingredients =============
Ingred Name:RADIUM 226
===================== Hazards Identification =====================
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
======================= First Aid Measures =======================
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
===================== Fire Fighting Measures =====================
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
================== Accidental Release Measures ==================
======================Handling and Storage ======================
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
SOURCE OF DATA-MIL HANDBOOK 600-1 SEP 76.SAFETY & HEALTH DATA DEVELOPED
BY DGSC-STF.
================== Physical/Chemical Properties ==================
HCC:A3
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-IN ACCORDANCE WITH
DOD REGULATIONS AND FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:EN ALKYD LUST QD GREEN 34108 ID 744422
Preparer's Name:W. A. ELLISON
CAGE:PRATT
CAGE:PRATT
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:VM&P NAPHTHA (SOLVENT) (LFL 0.9 - UFL 6.7)
CAS:8030-30-6
RTECS #:DE3030000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:300 PPM;STEL 400 PPM
ACGIH TLV:300 PPM;1350 MG/M3
Ingred Name:ISOBUTYL ALCOHOL (VAPOR PRESSURE 10 MM HG @ 20C) (LFL 1.0 -
UFL 11.0)
CAS:78-83-1
RTECS #:NP9625000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TOLUENE (SARA 313) (VAPOR PRESSURE 22 MM HG @ 20C) (LFL 1.7
- UFL 7.1)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: < 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ISOBUTYL ACETATE (LFL 2.0 - UFL 11.0)
CAS:110-19-0
RTECS #:AI4025000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM; 700 MG/M3
ACGIH TLV:150 PPM; 700 MG/M3
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:N-HEPTANE (VAPOR PRESSURE 40 MM HG @ 20C) (LFL 1.0 - UFL
7.0)
CAS:142-82-5
RTECS #:MI7700000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:500 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9293
Ingred Name:HEXANE (VAPOR PRESSURE 120 MMHG @ 20C) (LFL 1.0 - UFL 8.0)
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: < 1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:500 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:LEAD SULFOCHROMATE
CAS:1344-37-2
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.0500 MG/M3; C0.100
ACGIH TLV:0.0500 MG/M3
Ingred Name:ANTIMONY TRIOXIDE (SARA 313)
CAS:1309-64-4
RTECS #:CC5650000
Fraction by Wt: < 1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.5000 MG/M3
ACGIH TLV:0.5000 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: < 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:TALC
CAS:14807-96-6
RTECS #:MW2700000
Fraction by Wt: 25%
Other REC Limits:NONE SPECIFIED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:VOC: 4.12 LB/GAL LESS WATER & NPRS 494 G/L LESS WATER
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:REPEATED/PROLONGED OVEREXPO TO
CHROMATES CAUSE LUNG CANCER. REPEATED OVEREXPO TO TOLUENE CAUSE
LIVER DAMAGE. REPEATED OVEREXPO TO N-HEXANE CAUSE DAMAGE TO
PERIPHERAL NERVOUS SYSTEM. PRE-EXISTING KIDNE Y CONDITIONS
AGGRAVATED BY EXPOSURE TO LEAD. EXPOSURE TO METHLY ETHYL KETONE
INHANCE NEUROTOXICITY OF N-HEXANE.
Explanation of Carcinogenicity:CHROMIUM & CERTAIN CHROMIUM COMPOUNDS
ARE LISTED AS POTENTIAL CARCINOGENS BY THE NATIONAL TOXICOLOGY
PROGRAM.
Effects of Overexposure:INGESTION: CAN CAUSE GASTROINTESTINAL
IRRITATION, NAUSEA, & VOMITING. ASPIRATION OF MATERIAL INTO LUNG
CAUSE CHEMICAL PNEUMONITIS CAN BE FATAL. INHALATION: CAUSE NOSE OR
THROAT IRRITATION. HIGH CONCEN T CAUSE ACUTE CNS CHARACT BY
HEADACHES,DIZZINESS, NAUSEA, CONFUSION. EYE: IRRITATION. SKIN:
DEFATTING & IRRITATION.
Medical Cond Aggravated by Exposure:REPORTS HAVE ASSOCIATED
PROLONGED/REPEATED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH
PERMANENT BRAIN/NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING/INHALING HARMFUL OR FATAL.
======================= First Aid Measures =======================
First Aid:INGESTION: DO NOT INDUCE VOMITING. CALL POISON CONTROL
CENTER, HOSPITAL E.R. OR PHYSICIAN IMMEDIATELY. INHALATION: REMOVE
TO FRESH AIR. RESTORE BREATHING. KEEP WARM & QUIET. GET MEDICAL
ATTENTION. EYE : FLUSH WITH LARGE AMOUNTS OF WATER, OCCASIONALLY
LIFTING EYELIDS. GET MEDICAL ATTENTION. SKIN: FLUSH THE
CONTAMINATED AREA WITH LARGE AMOUNTS OF WATER. CONSULT A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:-9F,-23C
Autoignition Temp:Autoignition Temp Text:572 F
Lower Limits:0.9 %
Upper Limits:11.0 %
Extinguishing Media:USE NFPA CLASS B (CARBON DIOXIDE, DRY CHEMICAL, OR
ALCOHOL FOAM) DESIGNED FOR LIQUID FIRES. POLYMER FOAM FOR LARGE
FIRES
Fire Fighting Procedures:WEAR SCBA. WATER MAY BE INEFFECTIVE, USED TO
COOL EXPOSED CONTAINERS TO PREVENT PRESSURE BUILDUP, AUTOIGNITION,
EXPLOSION. IF WATER USED, FOG NOZZLES ARE PREFER
Unusual Fire/Explosion Hazard:DURING EMGERGENCY CONDITION, OVEREXPOSURE
TO DECOMPOSTION PRODUCTS MAY CAUSE HEALTH HAZARD. SYMPTOMS MAY NOT
BE IMMEDIATELY APPARENT. GET MEDICAL ATTENTION.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR RESPIRATORS & PROPER FULL BODY PROTECTION
APPROPIATE FOR THE SIZE OF THE SPILL. KEEP SPECTATORS AWAY.
ELIMINATE ALL IGNITON SOURCES. DIKE & CONTAIN SPILL WITH INERT
MATERIAL. USE ONLY NON-SPARKIN G TOOLS. PREVENT CONTAMINATION OF
ALL WATERWAYS.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE ABOVE 115F (46C). STORE
LARGE QUANTITIES IN COMPLIANCE WITH OSHA 29 CFR 1910.106. DON'T
TAKE INTERNALLY. CLOSE CONTAINER AFTER EACH USE.
Other Precautions:DON'T BREATHE SANDING DUST. EMPTY CONTAINERS MUST NOT
BE WASHED & RE-USED FOR ANY PURPOSE. CONTAINERS SHOULD BE GROUNDED
& BONDED TO THE RECEIVING CONTAINER. DO NOT WELD, BRAZE OR CUT ON
EMPTY CONTAIN ER. NEVER USE PRESSURE TO EMTPY DRUM.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:REFER TO OSHA STANDARD FOR SPECIFIC RESPIRATORY
PROTECTION REQUIREMENTS FOR LEAD, 29 CFR 1910.1025. RESTRICTED
VENTILATION ORGANIC VAPOR RESPIRATOR. DURING SPRAYING A MECHANICAL
PREFILTER. IN CONFINED AREAS OR IN HIGH EXPOSURE A AIRSUPPLIED
Ventilation:PROVIDE GENERAL DILUTION & LOCAL EXHAUST IN SUFFICIENT
VOLUME & PATTERN TO KEEP CONCENTRATION BELOW EXPOSURE LIMIT.
Other Protective Equipment:EYEWASH FACILITY, SAFETY SHOWER. AS REQUIRED
TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH HANDS AND FACE THOROUGHLY BEFORE EATING OR
DRINKING. REMOVE & WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:156 TO 278F
Melt/Freeze Pt:M.P/F.P Text:-50F,-46C
Decomp Temp:Decomp Text:1832F,1000C
Vapor Pres:120
Vapor Density:> AIR
Spec Gravity:1.2
pH:4-7
Viscosity:67-77 KU
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID, SOLVENT ODOR
Percent Volatiles by Volume:59
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS. OXIDIZING MATERIALS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT (>115F - 46C) AND
SOURCES OF IGNITION.
Hazardous Decomposition Products:BURNING, INCULDING HEATED BY
WELDING/CUTTING, WILL PRODUCE SMOKE, CARBON MONOXIDE, CARBON
DIOXIDE. OXIDES OF CHROMIUM.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE W/LOCAL, STATE & FEDERAL
REGULATIONS. INCINERATE ONLY IN EPA PERMITTED FACILITY. DON'T
INCINERATE CLOSED CONTIANERS. OBSERVE PRECAUTIONS FOR DISPOSAL OF
FLAMMABLE MATERIALS. CONT AMINATED ABSORBENT DISPOSE IN
HAZARDOUSLANDFILL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:8252W
CAGE:06980
CAGE:06980
CAGE:08594
============= Composition/Information on Ingredients =============
Ingred Name:THORIUM 232
CAS:7440-29-1
RTECS #:XO6400000
===================== Hazards Identification =====================
Effects of Overexposure:HAZARD DEGREE DEPENDS ON THE TYPE AND QUANTITY
OF RADIATION. LATENT EFFECTS: SOMATIC/GENETIC DAMAGE.
======================= First Aid Measures =======================
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE AND
ISOLATE COMTAMINATED CLOTHING. SHOWER VICTIM WITH SOAP AND WATER.
DETAIN PERSONNEL AND EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL
THAT VICTIM MA Y BE CONTAMINATED.
===================== Fire Fighting Measures =====================
Extinguishing Media:EXTINQUISH WITH AGENT SUITABLE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF
CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:SOME OF MATERIAL MAY BURN. CONTAINERS MAY
EXPLODE IN HEAT OF FIRE.
================== Accidental Release Measures ==================
======================Handling and Storage ======================
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM AND FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELF CONTAINED BREATHING APPARATUS IF INVOLVED
IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHANICAL (GENERAL/LOCAL EXHAUST) VENTILATION TO
MAINTAIN < TLV.
Other Protective Equipment:EYE WASH STATION, APRONS, SPECIAL IMPERVIOUS
CLOTHING
Supplemental Safety and Health
SOURCE OF DATA - MIL HANDBOOK 600-1 SEP 76. SAFETY AND HEALTH DATA
DEVELOPED BY DGSC-STF.
================== Physical/Chemical Properties ==================
HCC:A2
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ISOLATE AND SEGREGATE FROM MOST OTHER TYPE MATERIAL.
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED IN ACCORDANCE WITH
DOD REGULATIONS AND FEDERAL, STATE, AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CALCIUM HYPOCHLORITE,TECHNICAL (FSC6810)
CAGE:KO802
CAGE:0WTR2
CAGE:KO802
============= Composition/Information on Ingredients =============
Ingred Name:CALCIUM HYPOCHLORITE (SARA III)
CAS:7778-54-3
RTECS #:NH3485000
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS 1300 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CORROSIVE TO ALL TISSUE CONTACTED.
DECREASED APPETITE AND ACTIVITY WITH LARGE ORAL DOSES.
Effects of Overexposure:EYES/SKIN: SEVERE IRRITATION, BURNING, EYE
TEARING, EYE DAMAGE. INHALATION: COUGHING, DIFFICULTY BREATHING,
IRRITATION OF NOSE AND THROAT. MAY CAUSE PULMONARY EDEMA.
INGESTION: BURNING TO MOUTH, THROA T. AGDOMINAL CRAMPS, NAUSEA. MAY
LEAD TO CONVULSIONS, COMA, AND DEATH.
Medical Cond Aggravated by Exposure:PERSON WITH PRE-EXISTING DISEASE
INVOLVING THE EYES, SKIN, OR RESPIRATORY TRACT MAY BE AT INCREASED
RISK FROM EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH WITH LARGE AMOUNTS OF WATER. GET MEDICAL
ATTENTION. INHALATION: MOVE TO FRESH AIR. GET MEDICAL ATTENTION.
INGESTION: IF CONSCIOUS, RINSE MOUTH WITH WATER. GIVE LARGE AMOUNTS
OF WATER TO DRINK. DO NOT INDUCE VOMITING. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:NOT COMBUSTABLE BUT MAY IGNITE COMBUSTABLE
MATERIALS OR ORGANIC MATTER UPON CONTACT.
Fire Fighting Procedures:FLOOD WITH WATER TO KEEP FIRE-EXPOSED
CONTAINERS COOL. WEAR NIOSH APPROVED SCBA RECOMMENDED. FIRES CAN
SPREAD RAPIDLY. MATERIAL IS A POWERFUL OXIDIZER.
Unusual Fire/Explosion Hazard:DRUMS MAY RUPTURE EXPLOSIVELY IF
CONTAMINATED OR EXPOSED TO HEAT. IGNITES COMBUSTABLE MATERIALS AND
STRONG REDUCING AGENTS WHEN IN CONTACT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. DO NOT ALLOW
MATERIAL TO ENTER SEWERS OR WATERWAYS. CLEAN UP IN A MANNER TO
MINIMIZE CONTAMINATION WITH ORGANIC MATERIAL. PLACE IN CLEAN, DRY
CONTAINER OUT OF DOORS IN WELL VENTILATED AREA. DO NOT SEAL
CONTAINER.
Neutralizing Agent:USE HYDROGEN PEROXIDE, SODIUM BISULFITE, OR SODIUM
SULFITE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, WELL VENTILATED
AREA AWAY FROM HEAT, AND REACTIVE MATERIAL. WEAR PROPER PROTECTIVE
GEAR WHEN HANDLING TO MINIMIZE PRODUCT CONTACT.
Other Precautions:HANDLE MATERIAL WITH CARE. DO NOT DROP, ROLL, OR
SKID. KEEP UPRIGHT. DO NOT REUSE EMPTY CONTAINEERS. WASH WITH
PLENTY OF WATER AND DISCARD TO TRASH. KEEP AWAY FROM CHILDREN. USE
PRODUCT ONLY AS DIRECT ED. DO NOT SMOKE WHEN HANDLING MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED CHLORINE GAS/DUST
RESPIRATOR IF EXCESSIVE DUSTING OCCURS.
Ventilation:LOCAL EXHAUST IS NORMALLY ADEQUATE. IF PERMISSIBLE LIMITS
ARE EXCEEDED, ADDITIONAL VENTILATION/EXHAUST IS NECESSARY.
Other Protective Equipment:PROVIDE EYE WASH STATION AND SAFETY SHOWER
IN WORK AND STORAGE AREAS.UNIFORM AND BOOTS AS NECESSARY TO
MINIMIZE CONTACT.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
WHILE PRODUCT IS NOT A COMBUSTIBLE MATERIAL, IT MUST NOT BE MIXED OR
CONTAMINATED WITH FOREIGN MATERIALS SUCH AS: HOUSEHOLD PRODUCTS,
SOAPS, PAINTS, SOLVENTS, ACIDS, POOL CHEMICALS, GARBAGE, VINEGAR,
BEVERAGES, OILS, DIRTY RAGS, ETC. DAMPENED MATERIAL AND/OR
EXCESSIVE MOISTURE TO PRODUCT CAN RESULT IN FIRE OR REACTION.
================== Physical/Chemical Properties ==================
HCC:D1
Melt/Freeze Pt:M.P/F.P Text:DECOMP.350F
Decomp Temp:Decomp Text:350F,177C
Spec Gravity:BULK 0.95 GM/ML
pH:11.0
Solubility in Water:APPRECIABLE
Appearance and Odor:WHITE FREE FLOWING GRANULAR SOLID. CHLORINOUS ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SOAPS, SOLVENTS, ACIDS, COMBUSTABLES, ORGANICS, OTHER POOL CHEMICALS.
Stability Condition to Avoid:STABLE UP TO 180C. AVOID HUMIDITY,
TEMPERATURES ABOVE 100C, AND/OR ACIDIC ENVIRONMENT.
Hazardous Decomposition Products:CHLORINE BY REACTION WITH ACIDS.
OXYGEN BY HEATING.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF NEUTRALIZED MATERIAL IN ACCORDANCE
WITH LOCAL, STATE AND FEDERAL REGULATIONS. DISSOLVE WASTE IN LARGE
AMOUNTS OF WATER. ALWAYS ADDSMALL AMOUNTS OF PRODUCT TO LARGE
AMOUNTS OF WATER.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:CHLOROFORM, 4439
Resp. Party Other MSDS Num.:C2915
CAGE:70829
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:CHLOROFORM
CAS:67-66-3
RTECS #:FS9100000
Minumum % Wt:98.
Maxumum % Wt:100.
Other REC Limits:N/K
OSHA PEL:C240 MG/M3;C50 PPM
OSHA STEL:N/K
ACGIH TLV:49 MG/M3;10 PPM
ACGIH STEL:N/K
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:ETHYL ALCOHOL
CAS:64-17-5
RTECS #:KQ6300000
Minumum % Wt:0.
Maxumum % Wt:1.
Other REC Limits:N/K
OSHA PEL:1900 MG/M3;1000 PPM
OSHA STEL:N/K
ACGIH TLV:1880 MG/M3;1000 PPM
ACGIH STEL:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE TOXICOLOGICAL INFORMATION.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: ACTS AS A
RELATIVELY POTENT ANESTHETIC. IRRITATES RESPIRATORY TRACT AND
CAUSES CENTRAL NERVOUS SYSTEM EFFECTS, INCLUDING HEADACHE,
DROWSINESS, DIZZINESS. EXPOSURE TO HIGHER CONCENTR ATIONS MAY
RESULT IN UNCONSCIOUSNESS & EVEN DEATH. MAY CAUSE LIVER INJURY AND
BLOOD DISORDERS. PROLONGED EXPOSURE MAY LEAD TO DEATH DUE TO
IRREGULAR HEART BEAT AND KIDNEY AND LIVER DISORDERS. INGESTIO N:
CAUSES SEVERE BURNING IN MOUTH AND THROAT, PAIN IN THE CHEST AND
VOMITING. LARGE QUANTITIES MAY CAUSE SYMPTOMS SIMILAR TO
INHALATION. SKIN: CAUSES SKIN IRRITATION RESULTING IN REDNESS AND
PAIN. (EF FECTS OF OVEREXPOSURE)
Explanation of Carcinogenicity:CHLOROFORM: IARC MONOGRAPHS, SUPPLEMENT,
VOLUME 7, PAGE 152, 1998: GROUP 2B. NTP 8TH ANNUAL REPORT ON
CARCINOGENS, 1998: REASONABLY ANTICIPATED TO BE HUMAN CARCINOGEN.
HUMAN: LIVER/KIDNEY TUMORS, CENT RAL NERVOUS SYSTEM EFFECTS.
Effects of Overexposure:HEALTH HAZARDS: REMOVES NATURAL OILS. MAY BE
ABSORBED THROUGH THE SKIN. EYES: VAPORS CAUSE PAIN AND IRRITATION
TO EYES. SPLASHES MAY CAUSE SEVERE IRRITATION AND POSSIBLE EYE
DAMAGE. CHRONIC: PROLONGEDOR REPEATED EXPOSURE TO VAPORS MAY
CAUSE DAMAGE TO THE NERVOUS SYSTEM, THE HEART, THE LIVER, AND THE
KIDNEYS. CONTACT WITH LIQUID HAS DEFATTING EFFECT AND MAY CAUSE
CHRONIC IRRITATION OF SKIN WITH CR ACKING AND DRYING, AND
CORRESPONDING DERMATITIS. CHLOROFORM IS A SUSPECTED HUMAN
CARCINOGEN.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS OR EYE PROBLEMS, OR IMPAIRED LIVER, KIDNEY OR RESPIRATORY
FUNCTION MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THE SUBSTANCE.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTF RESP. IF
BRTHG IS DFCLT, GIVE OXYGEN. GET MED ATTN. INGEST: DO NOT INDUCE
VOMIT. GIVE LGE QTYS OF WATER. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCON PE RS. GET MED ATTN IMMED. SKIN: IMMED FLUSH W/PLENTY OF
WATER FOR AT LEAST 15 MINS WHILE REMOVING CONTAM CLTHG & SHOES. GET
MED ATTN IMMED. WASH CLTHG BEFORE REUSE. THORO CLEAN SHOES BEFORE
REUSE. EYES: IMMED FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS,
LIFTING LOWER & UPPER LIDS OCCAS. GET MED ATTN IMMED. NOTE TO MD:
BECAUSE KIDNEY & LIVER EFTS MAY BE DELAYED, KEEP VICTIM UNDER
OBSERVATION FOR 24- 48 HRS. (SUP DAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:USE ANY MEANS SUITABLE FOR EXTINGUISHING
SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:SLIGHT FIRE HAZARD WHEN EXPOSED TO HIGH
HEAT. OTHERWISE, PRACTICALLY NOT FLAMMABLE. SEALED CONTAINERS MAY
RUPTURE WHEN HEATED.
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA. WEAR APPROP PERS PROT EQUIP AS
SPECIFIED IN CTL MEASURES SECTION. ISOLATE HAZ AREA. KEEP UNNEC &
UNPROTECTED PERS FROM ENTERING. CONTAIN & RECOVER LIQ WHEN POSS.
COLLECT LIQ IN APPROP CONTR /ABSORB W/INERT MATL (E.G.,
VERMICULITE, DRY SAND, ETC), & PLACE IN CHEM WASTE CONTR. DO NOT
USE COMBUST MATLS, SUCH AS SAWDUST. DO NOT FLUSH TO SEWER! US REGS
(CERCLA) REQUIRE REPORTING (OTHER INFO)
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN TIGHTLY CLSD LIGHT-RESIST
CONTR, STORED IN COOL, DRY, VENTILATED AREA. PROTECT AGAINST
PHYSICAL DMG. ISOLATE FROM INCOMPATIBLE SUBSTANCES. WEAR SPECIAL
PROT EQUIP (CTL MEASURES SECTION) FOR MA INT BREAK-IN/WHERE EXPOS
MAY EXCEED ESTABLISHED EXPOS LEVELS.
Other Precautions:CONTRS OF THIS MATL MAY BE HAZ WHEN EMPTY SINCE THEY
RETAIN PROD RESIDUES (VAPS, LIQS); OBSERVE ALL WARNINGS & PREC
LISTED FOR PROD. CHLOROFORM ODOR THRESHOLD: 250 MG/M3. ODOR
THRESHOLD ONLY SERVES AS WARNING OF EXPOS; NOT SMELLING IT DOES
NOT MEAN YOU ARE NOT BEING EXPOSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF THE EXPOSURE LIMIT IS EXCEEDED, WEAR A NIOSH
APPROVED SUPPLIED AIR, FULL-FACEPIECE RESPIRATOR, AIRLINED HOOD, OR
FULL-FACEPIECE SELF-CONTAINED BREATHING APPARATUS. THIS SUBSTANCE
HAS POOR WARNING P ROPERTIES.
Ventilation:A SYS OF LOC &/OR GEN EXHST IS REC TO KEEP EMPLOYEE EXPOS
BELOW AIRBORNE EXPOS LIMS. LOC EXHST VENT IS GEN PREF BECAUSE IT
CAN CTL EMISSIONS OF (TRANSPORT INFO)
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER . WEAR IMPERVIOUS PROTECTIVE CLOTHING, INCLUDING BOOTS, LAB
COAT, APRON OR COVERALLS, AS APPROPRIATE, TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH HANDS, FACE, FOREARMS & NECK WHEN EXITING
RESTRICTED AREAS. SHOWER, DISPOSE OF OUTER CLTHG, CHANGE TO CLEAN
GARMENTS AT END OF DAY. AVOID CROSS-CONTAM OF STREET CLOTHES.
(STATE REGS)
Supplemental Safety and Health
FIRST AID PROC: ADMIN OF FLUIDS MAY HELP TO PVNT KIDNEY FAILURE. OBTAIN
BLOOD GLUCOSE, URINALYSIS, LIVER FUNC TESTS, CHEST X-RAY, & MONITOR
CARD FUNC & FLUID/ELECTROLYTE STATUS. MONITOR LIVER & KIDNEY FUNC
FOR 4-5 DAYS AFTER EXPOS. DISULFIRAM, ITS METABOLITES, & HIGH
CARBOHYDRATE DIET APPEAR TO PROTECT (OTHER INFO)
================== Physical/Chemical Properties ==================
Boiling Pt:=62.2C, 144.F
Melt/Freeze Pt:=-63.9C, -83.F
Vapor Pres:160 MM HG @ 20C (68F)
Vapor Density:4.1(AIR=1)
Spec Gravity:1.48 @ 20C/4C
Evaporation Rate & Reference:11.6 (BUTYL ACETATE=1)
Solubility in Water:0.8G/100G WATER @ 20C/68F
Appearance and Odor:CLEAR, COLORLESS LIQUID, WITH CHARACTERISTIC
ETHEREAL ODOR.
Percent Volatiles by Volume:100 @ 21C
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG CAUSTICS AND CHEMICALLY-ACTIVE METALS SUCH AS ALUMINUM,
MAGNESIUM POWDER, SODIUM, OR POTASSIUM; ACETONE, FLUORINE,
METHANOL, SODIUM METHOXIDE, DINITROGEN TETROXIDE, TERT-BUTOXIDE,
TRIISOPROPYLPHOSPHINE.
Stability Condition to Avoid:PH DECREASES ON PROLONGED EXPOSURE TO
LIGHT AND AIR DUE TO FORMATION OF HCL. AVOID LIGHT, HEAT, AIR AND
INCOMPATIBLES.
Hazardous Decomposition Products:MAY PRODUCE CARBON MONOXIDE, CARBON
DIOXIDE, HYDROGEN CHLORIDE AND PHOSGENE WHEN HEATED TO
DECOMPOSITION.
=================== Toxicological Information===================
Toxicological Information:CHLOROFORM: ORAL RAT LD50: 908 MG/KG; SKIN
RABBIT LD50: >20 GM/KG; INHAL RAT LC50: 47702 MG/M3/4H; IRRIT DATA:
SKIN RABBIT: 10 MG/24H OPEN MILD; EYE RABBIT: 20 MG/24H MOD;
INVESTIGATED AS TUMORIGEN, M UTAGEN, REPRO EFFECTOR. REPRO
TOXICITY: BIRTH DEFECTS HAVE BEEN SEEN IN RATS & MICE EXPOSED BY
INHAL OF CHLOROFORM AT CONCS >100 PPM IN AIR. INGEST OF CHLOROFORM
BY PREGNANT LAB ANIMALS HAS RESULTED I N FETOTOXICITY BUT NOT BIRTH
DEFECTS, & ONLY AT LEVELS CAUSING SEV MATERNAL EFTS. OTHER INFO:
LAB PROT EQUIP: GOGGS & SHIELD, LAB COAT & APRON, VENT HOOD, PROPER
===================== Ecological Information =====================
Ecological:WHEN RELEASED INTO SOIL, THIS MATL IS EXPECTED TO LEACH INTO
GROUNDWATER, & QUICKLY EVAPORATE. WHEN RELEASED INTO WATER, THIS
MATL IS EXPECTED TO QUICKLY EVAPORATE, & HAVE A HALF-LIFE BETWEEN 1
& 10 D AYS. THIS MATL HAS A LOG OCTANOL-WATER PARTITION COEFFICIENT
OF <3.0. THIS MATL IS NOT EXPECTED TO SIGNIFICANTLY BIOACCUMULATE.
WHEN RELEASED INTO AIR, THIS MATL MAY BE MOD DEGRADED BY RXN
W/PHOTOCHEM ICALLY-PRDCED HYDROXYL RADICALS, & BY PHOTOLYSIS. WHEN
RELEASED INTO AIR, THIS MATL MAY BE REMOVED FROM ATM TO MOD EXTENT
BY WET DEPOSITION. (SARA REGS)
==================== Disposal Considerations ====================
Waste Disposal Methods:WHATEVER CANNOT BE SAVED FOR RECOVERY/RECYCLING
SHOULD BE HANDLED AS HAZ WASTE & SENT TO RCRA APPROVED WASTE
FACILITY. PROCESSING, USE/CONTAMINATION OF PROD MAY CHANGE WASTE
MANAGEMENT OPTIONS. STATE & LOCAL DISP REGULATIONS MAY DIFFER FROM
FEDERAL DISPOSAL REGULATIONS. DISPOSE OF CONTAINER & UNUSED
CONTENTS I/A/W FEDERAL, STATE & LOC REQUIREMENTS.
=================== MSDS Transport Information ===================
Transport Information:DOMESTIC (LAND, D.O.T.): PROPER SHIPPING NAME:
RQ, CHLOROFORM; HAZ CLASS: 6.1; UN/NA: UN1888; PACKING GROUP: III;
INFO REPORTED FOR PROD/SIZE: 24.5 L. INTERNATIONAL (WATER, I.M.O.):
PROPER SHIPPING NA ME: CHLOROFORM; HAZ CLASS: 6.1; UN/NA: UN1888;
PACKING GROUP: III; INFO REPORTED FOR PROD/SIZE: 24.5 L. VENT:
CONTAMINANT AT ITS SOURCE, PREVENTING DISPERSION OF IT INTO GEN
WORK AREA. PLEASE REFER TOACGIH DOCUMENT, INDUS VENT, A MANUAL OF
RECOMMENDED PRACTICES, MOST RECENT EDITION, FOR DETAILS.
===================== Regulatory Information =====================
SARA Title III Information:CHLOROFORM (67-66-3): SARA 302 RQ: 10; SARA
302 TPQ: 10000; LISTED IN SARA 313; NOT LISTED IN SARA 313 CHEMICAL
CATEGORIES. ETHYL ALCOHOL (64-17-5): NOT LISTED IN SARA RQ/TPQ,
SARA 313 LIST, SARA 313 CHEMICAL CATEGORIES. SARA 311/312: ACUTE:
YES; CHRONIC: YES; FIRE: NO; PRESSURE: NO; REACTIVITY: NO
(MIXTURE/LIQUID). ECOLOGICAL INFO: WHEN RELEASED INTO AIR, THIS
MATERIAL IS EXPECTED TO HAVE A HALF- LIFE OF >30 DAYS.
ENVIRONMENTAL TOXICITY: THIS MATERIAL IS NOT EXPECTED TO BE TOXIC
TO AQUATIC LIFE. LC50/96-HR VALUE FOR FISH ARE >100 MG/L.
Federal Regulatory Information:CHLOROFORM (67-66-3)/ETHYL ALCOHOL
(64-17-5): LISTED IN TSCA, EC, JAPAN, AUSTRALIA, KOREA, CANADA DSL,
THE PHILLIPINES; NOT LISTED IN CANADA NDSL. CHLOROFORM (67-66-3):
CERCLA: 10; RCRA 261.33: U044; TSCA 8 (D): NO. ETHYL ALCOHOL
(64-17-5): NOT LISTED IN CERCLA, RCRA 261.33, TSCA 8 (D). CHEMICAL
WEAPONS CONVENTION: NO. TSCA 12 (B): NO. CDTA: NO. AUSTRALIAN
HAZCHEM CODE: 2Z. POISON SCHEDULE: S6. WH MIS: THIS MSDS HAS BEEN
PREPARED ACCPRDING TO THE HAZARD CRITERIA OF THE CONTROLLED
PRODUCTS REGULAT IONS (CPR) AND THE MSDS CONTAINS ALL OF THE
INFORMATION REQUIRED BY THE CPR.
State Regulatory Information:WARNING: THIS PRODUCT CONTAINS A CHEMICAL
KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER. HYGIENE
PRACTICES: WASH HANDS BEFORE EATING AND DO NOT EAT, DRINK, OR SMOKE
IN WORKPLACE. DO NOT BREATHE VAP OR. DO NOT GET IN EYES, ON SKIN,
OR ON CLOTHING. KEEP CONTAINER CLOSED. USE WITH ADEQUATE
VENTILATION. WASH THOROUGHLY AFTER HANDLING.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TOWER 392 SAFETY SOLVENT
Resp. Party Other MSDS Num.:P.O. BOX 3070/PALMER, PA 18043
CAGE:9W454
CAGE:9W454
============= Composition/Information on Ingredients =============
Ingred Name:METHYLCHLOROFORM (1,1,1-TRICHLOROETHANE) (CHLOROTHENE NU),
AEROTHANE TT, CHLOROTHENE (IARC CARC - GROUP 3)*97-4*
CAS:71-55-6
RTECS #:KJ2975000
Other REC Limits:450 PPM STEL
OSHA PEL:350 PPM
ACGIH TLV:350 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:DIETHYLENE ETHER (DIOXANE), (DIETHYLENE DIOXIDE),
1,4-DIOXANE (ANIMAL CARCINOGEN BY IARC GROUP 2B;CARC BY NTP) *97-3*
CAS:123-91-1
RTECS #:JG8225000
Fraction by Wt: <2.3%
Other REC Limits:25 PPM
OSHA PEL:360 MG/CUM
ACGIH TLV:90 MG/CUM (SKIN)
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INHALATION: DIZZINESS, HEADACHE, EYE
IRRITATION, CENTRAL NERVOUS SYSTEM DEPRESSION, UNCONSCIOUSNESS &
DEATH.
Explanation of Carcinogenicity:CONTAINS <2.3% DIETHYLENE ETHER. PURE
DIETHYLENE ETHER HAS SHOWN CARCINOGENIC EFFECTS IN LABORATORY
ANIMALS.
Effects of Overexposure:SKIN: MAY LEAD TO DERMATITIS. ABSORPTION
THROUGH MAY LEAD TO SYSTEMIC EFFECTS. INGESTION: IF VOMITING OCCURS
& ASPIRATED INTO LUNGS, CHEMICAL PNEUMONIA & SYSTEMIC EFFECTS.
Medical Cond Aggravated by Exposure:ACUTE/CHRONIC LIVER DISEASE, RHYTHM
DISORDERS OF THE HEART & RESPIRATORY.
======================= First Aid Measures =======================
First Aid:SKIN/EYE: FLUSH WITH WATER, GET MEDICAL ATTENTION.INHALATION:
REMOVE TO FRESH AIR, GET MEDICAL ATTENTION IF NECESSARY. INGESTION:
GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:7.5%
Upper Limits:15%
Extinguishing Media:USE DRY CHEMICAL OR CO2.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CONCENTRATED VAPORS MAY BE IGNITED BY
HIGH INTENSITY IGNITION SOURCE. CONTAINERS OF THIS PRODUCT MAY
RUPTURE FROM VAPOR PRESSURE WHEN EXPOSED TO HEAT FROM FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:MINOR SPILLS: ABSORB MATERIAL W/GROUND CLAY,
VERMICULITE, OR SIMILAR ABSORBENT MATERIAL, THEN PLACE INTO
CONTAINERS FOR REMOVAL. MAJOR SPILLS: DIKE/CONTAIN SPILL. ELIMINATE
POTENTIAL SOURCES OF IGNITI ON/SHUT OFF SOURCE OF SPILL IF
POSSIBLE.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T TAKE INTERNALLY. AVOID SKIN
CONTACT/WASH AFTER USING PRODUCT. DON'T EAT, DRINK, OR SMOKE IN
WORK AREA.
Other Precautions:REMOVE LIQUID BY CHEMICAL VACUUM, ABSORBENT, OR OTHER
SAFE & APPROVED METHOD & PLACE INTO CONTAINERS FOR LEGAL DISPOSAL.
FLUSH AREA W/WATER TO REMOVE RESIDUE & REMOVE FLUSHED SOLUTIONS AS
ABOVE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION IS INSUFFICIENT, USE NIOSH
APPROVED RESPIRATOR-AIR SUPPLIED OR ORGANIC VAPOR FILTERING TYPE.
Ventilation:VENTILATION SHOULD BE SUFFICIENT TO KEEP <TLV.
LOCAL/MECHANICAL EXHAUST RECOMMENDED.
Other Protective Equipment:SAFETY SHOES, EYEWASH FOUNTAIN.
Work Hygienic Practices:AVOID SKIN CONTACT/WASH AFTER USING PRODUCT.
DON'T EAT, DRINK, OR SMOKE IN WORK AREA. CONTACT LENSES SHOULD NOT
BE WORN.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:165F
Vapor Pres:100
Vapor Density:4.6
Spec Gravity:1.30
Evaporation Rate & Reference:(ISOPROPYL ALCOHOL): 500
Solubility in Water:0.07
Appearance and Odor:WHITE WATER LIQUID, TYPICAL CHLORINATED ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ALUMINUM & SOFT ALLOYS, ALKALIES.
Stability Condition to Avoid:AVOID EXPOSURE TO HIGH HEAT SOURCE,
WELDING ARCS, & OPEN FLAME. AVOID REACTIVE METALS.
Hazardous Decomposition Products:CO, PHOSGENE, CHLORINE, HYDROGEN
CHLORIDE, A CORROSIVE GAS, & OTHER COMPOUNDS DURING COMBUSTION.
Conditions to Avoid Polymerization:AVOID OPEN ELECTRICAL SOURCES NEAR
PRODUCT VAPOR AREAS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ALL WASTE IN ACCORDANCE WITH FEDERAL,
STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LEAD-ACID BATTERY
CAGE:20038
CAGE:0FTM0
CAGE:20038
============= Composition/Information on Ingredients =============
Ingred Name:LEAD (SARA III)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 60%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.05 MG/M3;1910.1025
ACGIH TLV:0.15 MG/M3;DUST 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ANTIMONY (SARA III)
CAS:7440-36-0
RTECS #:CC4025000
Fraction by Wt: 2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.5 MG/M3
ACGIH TLV:0.5 MG SB/M3; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ARSENIC (SARA III)
CAS:7440-38-2
RTECS #:CG0525000
Fraction by Wt: 0.2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.5 MG/M3 (AS)
ACGIH TLV:0.01,A1 MG/M3; 9394
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CALCIUM, METAL
CAS:7440-70-2
RTECS #:EV8040000
Fraction by Wt: 0.2%
Other REC Limits:NONE SPECIFIED
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
Fraction by Wt: 0.2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9192
Ingred Name:SULFURIC ACID (SARA III)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 10-30%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:POLYPROPYLENE
CAS:9003-07-0
RTECS #:TR5000000
Fraction by Wt: 5-10%
Other REC Limits:NONE SPECIFIED
Ingred Name:POLYSTYRENE
CAS:9003-53-6
RTECS #:WL6475000
Fraction by Wt: 5-10%
Other REC Limits:NONE SPECIFIED
Ingred Name:STYRENE ACRYLONITRILE
CAS:9003-54-7
Fraction by Wt: 5-10%
Other REC Limits:NONE SPECIFIED
Ingred Name:ACRYLONITRILE BUTADIENE STYRENE
CAS:9003-56-9
Fraction by Wt: 5-10%
Other REC Limits:NONE SPECIFIED
Ingred Name:STYRENE POLYMER WITH 1,3-BUTADIENE
CAS:9003-55-8
RTECS #:WL6478000
Fraction by Wt: 5-10%
Other REC Limits:NONE SPECIFIED
Ingred Name:POLYVINYL CHLORIDE RESIN
CAS:9002-86-2
Fraction by Wt: 5-10%
Other REC Limits:NONE SPECIFIED
Ingred Name:POLYCARBONATE
Other REC Limits:NONE SPECIFIED
Ingred Name:HARD RUBBER
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS 2140 MG/KG (H2SO4)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY CAUSE IRRITATION OF
RESPIRATORY TRACT, EYES, SKIN OR GI TRACT. MAY CAUSE BURNS OF SKIN,
EYES, OR GI TRACT. MAY CAUSE CORNEAL DAMAGE OR BLINDNESS. CHRONIC:
TOOTH EROSION, INFLAMMATION OF NOS E, THROAT AND BRONCHIAL TUBES.
Explanation of Carcinogenicity:THE ELECTROLYTE IS NOT LISTED BY IARC,
NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:INHALATION: BURNING SENSATION IN NOSE, THROAT
AND LUNGS, COUGHING, WHEEZING, SHORTNESS OF BREATH. EYES: REDNESS,
TEARING, BLURRED VISION, BURNS, SEVERE PAIN. SKIN: SEVERE PAIN,
BURNS, REDNESS, RASH, I TCHING. INGESTION: BURNS OF MOUTH, THROAT,
AND ESOPHAGUS, SEVERE STOMACH PAIN, NAUSEA, VOMITING.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE RESPIRATORY TRACT OR
TEETH MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
FOR 15 MINUTES HOLDING EYELIDS OPEN. GET PROMPT MEDICAL ATTENTION.
SKIN :REMOVE CONTAMINATED CLOTHING. WASH WITHPLENTY OF WATER FOR 15
MINUTES. GET MEDICAL ADVICE. INGESTION:DO NOT INDUCE VOMITING.
GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET IMMEDIATE MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE DRY CHEMICAL, CARBON DIOXIDE, FOAM, HALOGEN.
Fire Fighting Procedures:USE OF WATER IN EXTINGUISHING BURNING
BATTERIES MAY CAUSE SPATTERING DUE TO THE PRESENCE OF MOLTEN LEAD.
WEAR SCBA AND FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:AFTER ELECTROLYTE IS ADDED AND BATTERY IS
BEING CHARGED, HYDROGEN GAS IS PRODUCED. BATTERY MAY EXPLODE IF
HYDROGEN GAS TRAPPED INSIDE THE CASE SHOULD IGNITE.
================== Accidental Release Measures ==================
Spill Release Procedures:SHOULD A BATTERY BREAK OPEN, ISOLATE AREA.
ELECTROLYTE SHOULD BE ABSORBED WITH A NON-ORGANIC TYPE ABSORBENT
SUCH AS DRY SAND OR EARTH. AVOID DILUTION WITH WATER. LEAD SPILLED
FROM THE BATTERY SHOULD B E VACUUMED, DO NOT SWEEP OR USE
COMPRESSED AIR.
Neutralizing Agent:USE SODA ASH OR BAKING SODA TO NEUTRALIZE THE
ELECTROLYTE.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID THE USE OF UNINSULATED TOOLS. IF
THEY ARE REQUIRED, TAKE CARE NOT TO ELECTRICALLY SHORT THE
TERMINALS. REMOVE METAL JEWELRY BEFORE SERVICING.
Other Precautions:UNDER NORMAL CONDITIONS OF USE, EXPOSURE TO LEAD OR
LEAD CONTAINING COMPOUNDS DOES NOT OCCUR. SHOULD A BATTERY BREAK
OPEN AND A LEAD SPILL OCCUR, PRECAUTIONS SHOULD BE TAKEN TO PREVENT
LEAD DUST FROM BECOMING AIR BORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:UNDER NORMAL CONDITIONS OF USE, RESPIRATORY
PROTECTION IS NOT REQUIRED. HOWEVER, IF CONDITIONS ARISE THAT
REQUIRE THEIR USE, USE ONLY NIOSH/MSHA RESPIRATORS APPROVED FOR
DUST, FUME AND MIST.
Ventilation:BATTERY CHARGING AREAS MUST BE ADEQUATELY VENTILATED TO
PREVENT HAZARDOUS CONCENTRATIONS OF FLAMMABLE GAS OR ACID MIST.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE IMPERVIOUS WORK CLOTHING, BOOTS AND APRON AS
REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
RQ FOR CERCLA AND SARA III IS 1000 LBS (ELECTROLYTE). MSDS WRITTEN FOR
ELECTROLYE- IT IS THE PRIMARY HAZARD DURING NORMAL USE AND
HANDLING. INGREDIENTS FROM A LAUNDRY LIST FROM MFR: POLYPROPYLENE
IS M OST LIKELY INGREDIENT FOR CASE. INGREDIENT 1-5 IS ELECTRODE; 6
IS ELECTROLYTE; REST ARE FOR CASE.
================== Physical/Chemical Properties ==================
HCC:Z4
Boiling Pt:B.P. Text:203F,95C
Vapor Pres:10
Vapor Density:>1
Spec Gravity:1.23-1.35
pH:1
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:COMPLETE (ACID)
Appearance and Odor:NO ODOR. BATTERY CASE IS SEALED. ELECTROLYTE IS
CLEAR OILY LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONTACT OF ELECTROLYTE WITH ORGANIC MATERIAL AND COMBUSTIBLES, STRONG
ALKALIS, REDUCING AGENTS, STRONG OXIDIZING AGENTS
Stability Condition to Avoid:OVERCHARGING, SOURCES OF IGNITION
Hazardous Decomposition Products:SULFURIC ACID MIST, SULFUR DIOXIDE AND
CARBON MONOXIDE MAY BE RELEASED WHEN ELECTROLYTE DECOMPOSES.
==================== Disposal Considerations ====================
Waste Disposal Methods:BOTH ELECTROLYTE AND SCRAP BATTERIES ARE
REGULATED HAZARDOUS WASTE. SCRAP BATTERIES CONTAIN MATERIALS WHICH
ARE RECYCLABLE AND MUST BE RETURNED TO AUTHORIZED RECYCLER.
ELECTROLYTE SHOULD BE HAULED TO A PERMITTED TREATMENT FACILITY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:RATION HEATING/FUEL,COMPRESSED,TRIOXANE,MIL-F-10805D
Preparer's Name:DSCR-VBA(LEVIEN)
CAGE:KO155
CAGE:06421
CAGE:KO155
============= Composition/Information on Ingredients =============
Ingred Name:TRIOXANE
CAS:110-88-3
Fraction by Wt: 95%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5MG/M3 (RESPIR DUST)
ACGIH TLV:10MG/M3 (TOTAL DUST)
Ingred Name:METHYLENE BLUE(INGREDIENT 2 AND INGREDIENT 3 = 5%)
CAS:61-73-4
RTECS #:SO5600000
Other REC Limits:NONE RECOMMENDED
Ingred Name:MAGNESIUM STEARATE(INGREDIENT 2 AND INGREDIENT 3 = 5%)
CAS:557-04-0
RTECS #:WI4390000
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS 5G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SEVERE EYE INJURY.MAY CAUSE
RESPIRATORY IRRITATION.BURNING RELEASES FORMALDEHYDE.
Explanation of Carcinogenicity:FORMALDEHYDE(A DECOMPOSITION PRODUCT) IS
LISTED NTP,IARC AND OSHA.
Effects of Overexposure:INHAL(FORMALDEHYDE):BURNING SENSATION,TEARING.
Medical Cond Aggravated by Exposure:PERSONS WITH PREEXISTING
RESPIRATORY CONDITIONS MAY BE ADVERSELY AFFECTED BY THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING.WASH WITH WATER.GET MEDICAL
ATTENTION.EYES:WASH WITH WATER.GET MEDICAL ATTENTION.INHAL:REMOVE
FROM EXPOSURE.GIVE OXYGEN OR CPR IF NEEDED.GET MEDICAL
ATTENTION.INGEST: GET PROMPT QUALIFIED MEDICAL ATTENTION.IF
CONSCIOUS,RINSE MOUTH WITH WATER,THEN DRINK 2 GLASSES OF WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:OC
Flash Point:113F,45C
Lower Limits:3.6
Upper Limits:29
Extinguishing Media:WATER SPRAY,CARBON DIOXIDE,DRY CHEMICAL,FOAM.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL FIREFIGHTING GEAR.
Unusual Fire/Explosion Hazard:MAY EMIT TOXIC FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE SOURCES OF IGNITION.USE PROPER
RESPIRATORY AND PROTECTIVE EQUIPMENT.SWEEP INTO A DUSTPAN;PLACE IN
APPROPRIATE CONTAINER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY,WELL-VENTILATED
AREA.KEEP CONTAINER TIGHTLY CLOSED.KEEP AWAY FROM SOURCES OF
IGNITION.
Other Precautions:ANYDROUS CONDITIONS CAUSE SLOW POLYMERIZATION.HEAT
ABOVE 300F GENERATES FORMALDEHYDE.SUBLIMES IN THE PRESENCE OF AIR.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF HEATED ABOVE 300F OR WHILE IN CONFINED SPACES
USE A SELF-CONTAINED BREATHING APPARATUS.
Ventilation:USE LOCAL EXHAUST.
Other Protective Equipment:PROVIDE A LOCAL EYE WASH STATION AND SAFETY
SHOWER.
Work Hygienic Practices:USE REASONABLE CARE IN HANDLING THIS ITEM.
Supplemental Safety and Health
HMIS SPOKE TO MARK LAMENSDORF AT TRUTECH ON 21JAN97.THE MSDS WAS
PREPARED FOR A TECHNICAL SUPPORT REQUEST,USING THE BEST AVAILABLE
INFORMATION.THE PEL FOR FORMALDEHYDE IS 0.75PPM(TWA-8HR);2PPM
STEL;TL V IS 0.3PPM(CEILING).
================== Physical/Chemical Properties ==================
HCC:F8
Boiling Pt:B.P. Text:238F,114C
Melt/Freeze Pt:M.P/F.P Text:142F,61C
Vapor Pres:10
Vapor Density:<1.2
Spec Gravity:1.17
Solubility in Water:APPRECIABLE
Appearance and Odor:BARS.WHITE SOLID NEEDLE-LIKE PRISMATIC
CRYSTALS,SWEET ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS AND STRONG MINERAL ACIDS.
Stability Condition to Avoid:HIGH HEAT.FORMALDEHYDE IS PRODUCED ABOVE
302F.THIS MATERIAL SUBLIMES WHEN EXPOSED TO AIR.
Hazardous Decomposition Products:CARBON MONOXIDE,CARBON
DIOXIDE,FORMALDEHYDE,PARAFORMALDEHYDE.
Conditions to Avoid Polymerization:POLYMERIZES SLOWLY UNDER ANHYDROUS
CONDITIONS(AN ENVIRONMENT WITHOUT WATER).
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.INCINERATION IS RECOMMENDED.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PHILLYBOND BLUE 6A RESIN
Kit Part:Y
CAGE:20420
CAGE:20420
CAGE:65090
============= Composition/Information on Ingredients =============
Ingred Name:BISPHENOL A DIGLYCIDYL ETHER RESIN (MODERATE SKIN
SENSITIZER, SKIN IRRITANT)
CAS:25068-38-6
Fraction by Wt: >60%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL(RAT)2000 MG/KG,DERMAL(RAB)>20,000
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES AND SKIN:MODERATE IRRITANT.
INHALATION NOT LIKELY TO PRODUCE ANY ADVERSE EFFECTS. INGESTION:
GENERALLY CONSIDERED TO HAVE A LOW ORDER OF ACUTE ORAL TOXICITY.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN AND EYE ALLERGIES
MAY INCREASE THE CHANCE OF DEVELOPING INCREASED ALLERGY SYMPTOMS
FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER FOR AT LEAST 15 MINS.W/EYELIDS OPEN
SKIN:REMOVE CONTAMINATED CLOTHING, WASH W/PLENTY SOAP & WATER.GET
MD. INHALATION:MOVE TO FRESH AIR. ADMINISTER OXYGEN IF BREATHING
DIFFICULTY.GET MD.INGESTION:DO NOT INDUCE VOMITING.GIVE MILK/WATER
TO DILUTE. IMMEDIATELY GET MD.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F,>93C
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR SCBA IN CONFINED
AREAS
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID PERSONAL CONTACT. SCRAPE UP AS MUCH
MATERIAL AS POSSIBLE AND PLACE IN A SUITABLE, LABELED, CONTAINER
FOR WASTE DISPOSAL. RESIDUE MAY BE REMOVED USING A SAFETY SOLVENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL/DRY PLACE W/VENTILATION.
KEEP AWAY FROM OPEN FLAMES AND HIGH TEMP. PRACTICE GOOD
HOUSEKEEPING. WASH AFTER HANDLING.
Other Precautions:TAKE PROPER PRECAUTIONS AGAINST OVEREXPOSURE TO THE
DUSTS THAT MAY BE GENERATED FROM SANDING OR MACHINING THE CURED
MATERIAL. HANDLE IN ACCORDANCE W/THE HAZARD POTENTIAL OF CURING
AGENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT ORDINARILY REQUIRED FOR RESIN. DUST MASKS
SHOULD BE WORN DURING ANY GRINDING OR MACHINING PROCEDURES ON CURED
RESIN.NIOSH APPROVED RESPIRATORS MAY BE REQUIRED IN CONFINED AREAS
Ventilation:GENERAL MECHANICAL VENTILATION IS USUALLY ADEQUATE FOR MOST
INDUSTRIAL APPLICATIONS.
Other Protective Equipment:LONG-SLEEVE AND LONG LEG CLOTHING
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
KEY1:N1.
================== Physical/Chemical Properties ==================
HCC:T6
Boiling Pt:B.P. Text:530F,277C
Spec Gravity:1.24
Evaporation Rate & Reference:(BUAC=1) NIL
Solubility in Water:SLIGHT
Appearance and Odor:BLUE PASTE WITH SLIGHT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
ALDEHYDES, AND ACIDS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/APPLICABLE FEDERAL,
STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: 62-4437-0928-2 00-21200-25463-5, 3M SUPER 77 (SUPDAT)
Cage: 1BY21
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 76381
Cage: 1BY21
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYE CONT:MOD IRRIT:SIGNS/SYMPS CAN INCL REDNESS, SWELL,
PAIN, TEARING & HAZY VISION. SKIN CONT:MILD IRRIT(AFTER PRLNG/RPTD
CONT):SIGNS/SYMPS CAN INCL REDNESS, SWELL & ITCH. INHAL:INTENTIONAL CONC
& IN HAL MAY BE HARMFUL/FATAL. CNS DEPRESS:SIGNS/SYMPS CAN INCL HDCH,
DIZZ, DROW, INCOORD, SLOWED RXN TIME, (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:SLURRED SPEECH, GIDD & UNCON.
IRRIT(UPPER RESP):SIGNS/SYMPS CAN INCL SORENESS OF NOSE & THROAT, COUGH
& SNEEZING. INGEST:NOT LIKELY RTE OF EXPOS TO PROD. WHILE FOLLOWING EFTS
ARE ASSOC W/ONE OR MORE OF INDIVIDUAL INGS IN PROD & ARE REQD TO BE INCL
ON MSDS BY U.S. OSHA HAZ COMMUNICATION STD, THEY ARE
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES:IMMEDIATELY FLUSH W/LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. GET IMMEDIATE MEDICAL ATTENTION. SKIN:FLUSH W/LARGE AMOUNTS OF
WATER. IF IRRITATION PERSISTS, GET MEDICAL ATTENTION. INHAL:REMO VE PERSON TO
FRESH AIR. IF NOT BREATHING, GIVE ARTF RESP. IF BREATHING IS DIFFICULT, GET
IMMEDIATE MEDICAL ATTENTION. INGEST:DO NOT INDUCE VOMITING. DRINK TWO GLASSES
OF WATER. CALL MD.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REFER TO OTHER SECTIONS OF THIS MSDS FOR INFO
REGARDING PHYSICAL & HLTH HAZS, NIOSH APPRVD RESP PROT, VENT & PPE.
IN U.S.A., CALL (612)733-1110 OR (612)733-6100 FOR 24-HR SPILL ASSISTANCE.
VENT AREA. EXTING ALL IGNIT SOURCES. COVER W/ABSORB (SUPDAT)
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISP MUST BE I/A/W FED, STATE & LOC REGS (FP N).
INCIN IN PERMITTED HAZ WASTE INCIN IN PRESENCE OF COMBUST MATL. FACILITY MUST
BE CAPABLE OF HNDLG AEROSOL CANS. DISP OF EMPTY CANS IN SANIT LANDFILL. D ISP
OF WASTE PROD IN FACILITY PERMITTEDTO
Handling And Storage Precautions: AVOID EYE CONT W/VAP, SPRAY/MIST. AVOID
PRLNG/RPTD SKIN CONT. AVOID BRTHG OF VAPS, MISTS/SPRAYS. DO NOT INGEST. STORE
AT TEMPS <120F (49C).
Other Precautions: STORE OUT OF DIRECT SUNLIGHT. KEEP OUT OF REACH OF CHILDREN.
AEROSOL CNTNR CNTNS FLAMM GAS UNDER PRESS. KEEP AWAY FROM HEAT, SPKS, OPEN
FLAME & OTHER SOURCES OF IGNIT. EXTREMELY FLAMM LIQ & VAP. DO NO T
PIERCE/BURN CNTNR, EVEN AFTER (SUPDAT)
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: -42F,-41C
Upper Limits: FLAMM GAS
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: CLASS IA FLAMM LIQ. CLSD CNTNRS EXPOS TO HEAT
FROM FIRE MAY BUILD PRESS & EXPLODE. VAPS MAY TRAVEL LONG DISTS ALONG
GROUND/FLOOR TO IGNIT SOURCE & FLASH BACK.
=======================================================
Control Measures
=======================================================
Respiratory Protection: SELECT ONE OF THE FOLLOWING NIOSH APPROVED RESPIRATORS
BASED ON AIRBORNE CONCENTRATION OF CONTAMINANTS & I/A/W OSHA REGULATIONS:
HALF-MASK ORGANIC VAPOR RESPIRATOR.
Ventilation: DO NOT USE IN CONFINED AREA(S) W/LITTLE/NO AIR MOVEMENT. IF EXHST
VENT IS NOT ADEQ, USE APPROP NIOSH APPRVD RESP
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: NOTE:USERS OF "L" VERSION SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). MFR'S TRADE NAME/PART NO:SPRAY ADHESIVE. BP
& VP:COMPRESSED GAS. SPILL PROC:MATL. COLLECT USING NON-SPARKING TOOLS.
PLACE I N U.S. DOT-APPRVD CNTNR. OTHER PREC:USE. NO SMOKING WHILE HNDLG THIS
MATL. AVOID STATIC DISCHARGE.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: SUPP DATA
Vapor Pres: SUPP DATA
Vapor Density: 2.97
Spec Gravity: 0.697 (H*2O=1)
VOC Pounds/Gallon: 4.4
PH: 6.7
VOC Grams/Liter: 527
Evaporation Rate & Reference: 1.90 (ETHER=1)
Solubility in Water: NIL
Appearance and Odor: LIQUID IN AEROSOL, LIGHT CREAM COLORED; SWEET/FRUITY ODOR.
Percent Volatiles by Volume: 75(WT)
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEAT.
Materials To Avoid: NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products: CARBON MONOXIDE & CARBON DIOXIDE, TOXIC
VAPORS, GASES OR PARTICULATES.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: VOLATILE ORGANIC COMPOUNDS (SCAQMD METHOD 305): 75%; 4.4
LBS/GAL (527 G/L - LESS H*2O & EXEMPT SOLVENTS).
=======================================================
HAZCOM Label
=======================================================
Product ID: 62-4437-0928-2 00-21200-25463-5, 3M SUPER 77 (SUPDAT)
Cage: 1BY21
Company Name: MINNESOTA MINING AND MFG CO ENGINEERING DOCUMENT SYSTEMS DIV
Street: 3M CTR
Zipcode: 55144-1000
Label Required IND: Y
Date Of Label Review: 12/23/1997
Status Code: C
Label Date: 12/23/1997
Origination Code: G
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMM. ACUTE:EYE CONT:MOD IRRIT:REDNESS, SWELL, PAIN,
TEARING & HAZY VISION. SKIN CONT:MILD IRRIT(AFTER PRLNG/RPTD
CONT):REDNESS, SWELL & ITCH. INHAL:INTENTIONAL CONC & INHAL MAY BE
HARMFUL/FATAL. CNS DEPRESS:HDCH, DIZZ, DROW, INCOORD, SLOWED RXN TIME,
SLURRED SPEECH, GIDD & UNCON. IRRIT (UPPER RESP):SORENESS OF NOSE &
THROAT, COUGH & SNEEZING. INHAL:KIDNEY EFTS:REDUCED URINE VOL, BLOOD IN
URINE & BACK PAIN. LIVER EFTS:YELLOW SKIN (JAUN) & SORE UPPER ABDOM.
PERIPHERAL NEUROPATHY:TINGLING EXTREMS, INCOORD, NUMB, WEAK & TREMORS.
INGEST:GI IRRIT; PAIN, VOMIT, ABDOM TENDERNESS, NAUS, BLOOD IN VOMI TUS &
FECES. CHRONIC:NONE LISTED BY MANUFACTURER.
=======================================================
| 1 | eyes_protection_mandatory |
Subsets and Splits
No saved queries yet
Save your SQL queries to embed, download, and access them later. Queries will appear here once saved.