text
stringlengths 595
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:SOLDERING TIP,REPLACEMENT PART WL1-7
CAGE:28493
CAGE:28493
============= Composition/Information on Ingredients =============
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE
Effects of Overexposure:NONE
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:NONE NORMALLY REQUIRED.
===================== Fire Fighting Measures =====================
Extinguishing Media:METAL TIP NOT FLAMMABLE.
Fire Fighting Procedures:NOT APPLICABLE.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:NONE
Other Protective Equipment:NONE
Work Hygienic Practices:NONE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:INSOLUBLE
Appearance and Odor:1/16 INCH DIAMETER METAL SOLDERING IRON TIP.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NO INCOMPATABLE MATERIAL HAZARD.
Stability Condition to Avoid:NO UNSTABLE CONDITIONS TO AVOID.
Hazardous Decomposition Products:NONE
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:NONE
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:NATURE SOL EMULSION
CAGE:94058
CAGE:94058
============= Composition/Information on Ingredients =============
Ingred Name:DIPROPYLENE GLYCOL, MONOMETHYL ETHER; (DIPROPYLENE GLYCOL
METHYL ETHER) (DPM)
CAS:34590-94-8
RTECS #:JM1575000
Fraction by Wt: 10-20%
OSHA PEL:100 PPM;150 STEL, S
ACGIH TLV:100 PPM;150 STEL, S
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DIRECT EYE CONTACT MAY CAUSE
IRRITATION. EXCESSIVE INHALATION MAY CAUSE NASAL AND RESPIRATORY
IRRITATION. PROLONGED OR REPEATED SKIN CONTACT MAY CAUSE
IRRITATION. INGESTION MAY CAUSE GASTROINTESTINAL IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:EYE IRRITATION SEEN AS REDNESS, TEARING.
EXCESSIVE INHALATION MAY CAUSE DROWSINESS, LIGHTHEADEDNESS,
WEAKNESS, HEADACHE.SKIN IRRITATION SEEN AS SLIGHT REDNESS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. ADMINISTER OXYGEN IF BREATHING IS
DIFFICULT. EYE:FLUSH W/LARGE QUANTITIES OF WATER FOR AT LEAST 15
MINUTES, LIFTING UPPER & LOWER LIDS OCCASIONALLY. SKIN:WASH W/MILD
SOAP & WATER. REMOVE CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE.
INGEST: IF CONSCIOUS, DILUTE BY GIVING 2 GLASSES OF WATER. KEEP
WARM, QUIET. GET IMMEDIATE MD ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:126F,52C
Extinguishing Media:WATER FOG, ALCOHOL FOAM, CARBON DIOXIDE, DRY
CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . WATER FOG MAY BE USED TO COOL CLOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:NEVER USE WELDING OR CUTTING TORCH ON OR
NEAR DRUM, EVEN EMPTY.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AREA
WELL. ABSORB ON SOLID ABSORBENT AND SHOVEL INTO CONTAINERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BETWEEN 40 AND 100F.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV IS EXCEEDED, USE A NIOSH/MSHA APPROVED
RESPIRATOR. CONTACT YOUR LOCAL SAFETY EQUIPMENT SUPPLIER FOR
RECOMMENDATIONS.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENRAL AND/OR LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment:NONE
Work Hygienic Practices:AVOID BREATHING SPRAY MIST.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:20.0F,-6.7C
Vapor Pres:0.55 @ 77F
Vapor Density:5.14
Spec Gravity:1.004 (H2O=1)
Evaporation Rate & Reference:1.0 (WATER = 1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR YELLOWISH LIQUID WITH MILD CITRUS ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:CO, CO2 UPON THERMAL DECOMPOSITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE ACCORDING TO FEDERAL, STATE AND LOCAL
LAWS AND 40 CFR.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SILVER IODATE, 84
Preparer's Name:LM
CAGE:GFSCH
CAGE:77964
CAGE:GFSCH
============= Composition/Information on Ingredients =============
Ingred Name:SILVER IODATE
CAS:7783-97-3
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NOT CONSIDERED A HEALTH HAZARD.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN: WASH WITH WATER AFTER CONTACT. EYE: FLUSH WITH WATER
FOR AT LEAST 15 MINUTES . IF EYE IRRITATION PERSISTS, SEE
PHYSICIAN. INHALATION: REMOVE FROM EXPOSURE. SUPPORT BREATHING
(GIVE ARTIFICI AL RESPIRATION/OXYGEN) . INGESTION: CALL MD
IMMEDIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:OXIDIZING MATERIAL. MAY CAUSE FIRE IN
CONTACT WITH FLAMMABLE OR COMBUSTIBLE MATERIALS.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP AND SAVE FOR SILVER RECOVERY.
DISPOSAL TO SEWER IS REGULATED IN MOST AREAS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE GOOD LABORATORY PRACTICES.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:GENERAL VENTILATION SUFFICIENT TO KEEP AIRBORNE
CONCENTRATION BELOW CURRENT EXPOSURE LIMITS .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:0.003 G/100 ML @ 10C
Appearance and Odor:WHITE-GREY POWDER, ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH FLAMMABLES AND COMBUSTIBLES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PHOTAC-BOND APLICAP POWDER
CAGE:JO544
CAGE:JO544
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC: NONE SPECIFIED BY
MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
OXYGEN OR ARTIFICIAL RESPIRATION) . EYES: FLUSH PROMPTLY WITH
FLOWING WATER FOR AT LEAST 15 MINUTES. IF IRRITATION DEVELOPS,
CONSULT MD. SKIN: FLUSH WITH COPIOUS AMOUNTS OF WATER. SEE MD .
INGESTION: CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP UP AND DISCARD IN A SUITABLE CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY AREA AWAY FROM
FOODSTUFF AND BEVERAGES. DO NOT EAT, DRINK, OR SMOKE WHEN USING.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE CARRIED OUT IN ACCORDANCE WITH
STATE AND LOCAL REGULATIONS. DISPOSE OF IN ACCORDANCE WITH LOCAL,
STATE AND FEDERAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FA9842
CAGE:JO774
CAGE:81831
CAGE:JO774
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMED.SKIN:WASH W/SOAP IMMED.INHAL:REMOVE
TO FRESH AIR.GIVE ART.RESPIR. AS NEEDED.INGEST:GET MEDICAL
ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE VOMITING,BUT DO NOT MAKE
UNCONSCIOUS PE RSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS.CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE,THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW COLORED LIQUID,AROMATIC ODOR.
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:AIR SANITIZER 7 OZ (ALSO LIME & BOUQUET FRAGRANCE)
Preparer's Name:JCA
CAGE:TIMEM
CAGE:9C200
CAGE:81728
CAGE:TIMEM
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ALCOHOL (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 0 - 30%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9394
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 0 - 30%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:400 PPM
ACGIH TLV:400 PPM/500STEL;9394
Ingred Name:N-ALKYL (50% C14;40% C12;10% C16) DIMETHYL BENZYL AMMONIUM
CHLORIDE
Fraction by Wt: 0.17%
Other REC Limits:NONE RECOMMENDED
Ingred Name:PROPANE (TOTAL PERCENTAGE OF INGREDIENTS 4, 5 AND 6: 55.)
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: SEE ING
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9394
Ingred Name:ISOBUTANE
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: SEE # 4%
Other REC Limits:NONE RECOMMENDED
Ingred Name:N-BUTANE
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: SEE # 4%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:800 PPM (RTECS)
ACGIH TLV:800 PPM (RTECS)
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV 763 MG/M3, APPROX. PER MSDS.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, RESPIRATORY TRACT.
ACUTE- MAY CAUSE SEVERE EYES IRRITATION. IF AREA IS GROSSLY
MISTREATED, IRRITATION OF MUCOUS MEMBRANE IS POSSIBLE. REPEATED OR
PROLONGED SKIN CONTACT MAY CAUSE D EFATTING AND IRRITATION.
INGESTION IS UNLIKELY. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES, SKIN, RESPIRATORY TRACT IRRITATION
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION MAY BE
MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALATION:REMOVE TO
FRESH AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR
15 MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP & WATER.
INGESTION:U NLIKELY.
===================== Fire Fighting Measures =====================
Flash Point:FLAMMABL AEROSOL
Extinguishing Media:CARBON DIOXIDE, FOAM, SAND/DRY CHEMICAL. AVOID
SPREADING ANY BURNING LIQUID WITH WATER SPRAY. WATER MAY BE
INEFFECTIVE.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS. COOL
FIRE-EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:SPRAY CANS UNDER PRESSURE. EXTREMELY
FLAMMABLE. EXPLOSION HAZARD EXISTS WHEN SPRAY CANS HEATED. DO NOT
ENTER SPRAY CAN STORAGE AREA IF FIRE PRESENT.
================== Accidental Release Measures ==================
Spill Release Procedures:LEAKING CONTAINERS SHOULD BE PLACED OUTDOORS,
IN AN OPEN CONTAINER, AWAY FROM SOURCES OF IGNITION. ALLOW PRESSURE
TO DISSIPATE. VENTILATE AREA. ABSORB LIQUID WITH NON-FLAMMABLE
ABSORBENT MATERIALS AND PLACE IN CONTAINER FOR DISPOSAL.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE SPRAY CANS IN COOL, WELL
VENTILATED AREAS AWAY FROM SOURCES OF IGNITION SUCH AS SPARKS,
FLAMES, WELDING ARCS, SUNLIGHT. DO NOT STORE ABOVE 130F.
Other Precautions:"EMPTY" CONTAINERS RETAIN RESIDUE & MAY BE DANGEROUS.
AVOID REPEATED/PROLONGED SKIN CONTACT. KEEP OUT OF REACH OF
CHILDREN. AVOID EYE CONTACT. READ LABEL. THIS UNIT IS DESIGNED TO
SAFELY TREAT 6000 CU BIC FEET AND SHOULD BE USED ACCORDINGLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED. IF TLV IS EXCEEDED, WEAR
NIOSH-APPROVED ORGANIC VAPOR RESPIRATOR OR AIR-PURIFYING
RESPIRATOR. IN EMERGENCY, WEAR A NIOSH-APPROVED POSITIVE-PRESSURE
SELF-CONTAINED BREATHING APPARATUS.
Ventilation:SUFFICIENT VENTILATION TO KEEP VAPOR CONCENTRATION BELOW
TLV. LOCAL EXHAUST PREFERRED.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWERS SHOULD BE
AVAILABLE IN THE IMMEDIATE VICINITY OF ANY POTENTIAL EXPOSURE.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
EPA REG. NUMBER: 7710-1.
================== Physical/Chemical Properties ==================
HCC:V3
NRC/State Lic Num:NOT RELEVANT
Vapor Pres:3621
Spec Gravity:1.04
Viscosity:NOT KNOWN
Solubility in Water:APPRECIABLE
Appearance and Odor:VERY DRY SPRAY WITH MILD PERFUME ODOR
Percent Volatiles by Volume:88
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES, DIRECT SUNLIGHT,
TEMPERATURES ABOVE 130F, HOT SURFACES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. DO NOT PUNCTURE, INCINERATE SPRAY CANS.
DISPOSE OF EMPTY CANS IN TRASH PICK-UP. DO NOT PLACE IN HOME TRASH
COMPACTOR.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:6604102 B4-BIOTIN
Preparer's Name:S HEALY
CAGE:FO645
CAGE:FO645
CAGE:6Z677
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM AZIDE, AZIDE *96-4*
CAS:26628-22-8
RTECS #:VY8050000
Other REC Limits:0.1 PPM
ACGIH TLV:C 0.29 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NASAL IRRITATION. SKIN:
IRRITATION, ABSORPTION, ALLERGIC REACTION. EYES: IRRITATIONS,
CONJUNCTIVITIS. INGESTION: BRONCHIAL IRRITATION, RESPIRATORY
IRRITATION, RESPIRATORY FAILURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, FAINTNESS,
NAUSEA, LOW BLOOD PRESSURE, BLURRED VISION, SHORTNESS OF BREATH,
COLLAPSE, BRONCHITIS, PALPITATION, WEAKNESS & UNSTEADINESS, COMA,
CONVULSIONS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE CPR.
IF BREATHING IS DIFFICULT GIVE OXYGEN. SKIN: WASH OFF THOROUGHLY
FOR 15 MINS. EYES: RINSE THOROUGHLY W/WATER & GIVE PLENTY OF WATER
TO DRIN K. INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICALS SUCH AS AN SODIUM CARBONATE/SAND.
Fire Fighting Procedures:BURNING SODIUM AZIDE WILL EXPLODE IF WATER IS
USED AS AN EXTINGUISHING MEDIA. SCBA MUST BE WORN.
Unusual Fire/Explosion Hazard:MAY EXPLODE & RELEASE TOXIC FUMES UPON
HEATING. DON'T ALLOW TO CONTACT METALS AT HIGH TEMPS.
(SUPP)
================== Accidental Release Measures ==================
Spill Release Procedures:DILUTE W/RUNNING WATER BEFORE DISCHARGE.
DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM METALS & ACIDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Ventilation:GENERAL/LOCAL EXHAUST TO MEET TLV REQUIREMENTS
Other Protective Equipment:ADEQUATE LABORATORY ATTIRE
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
UNUSUAL FIRE CONT'D: FORMS HIGHLY SENSITIVE EXPLOSIVE COMPOUNDS W/HEAVY
METALS SUCH AS LEAD, SILVER & COPPER. WHEN HEATED TO 662F IT
DECOMPOSES EXOTHERMICALLY, BURNING W/A VERY HOT FLAME & PRODUCING N
ITROGEN & MOLTEN SODIUM.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:527F
Spec Gravity:1.85
Solubility in Water:40.16
Appearance and Odor:WHITE-COLORLESS CRYSTALS/POWDER, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
METALS, ACIDS, ACID CHLORIDES & STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT
Hazardous Decomposition Products:NITROGEN OXIDES, HYDRAZOIC ACID
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FIBER GLASS INSULATION, SUPERVANE
Resp. Party Other MSDS Num.:1009-5.1
CAGE:75165
CAGE:75165
CAGE:GO563
============= Composition/Information on Ingredients =============
Ingred Name:GLASS, OXIDE, CHEMICALS; (FIBER GLASS WOOLS)
CAS:65997-17-3
Minumum % Wt:50.
Maxumum % Wt:98.
Ingred Name:BINDER MAY BE EITHER INGREDIENT 3 OR 4
Ingred Name:UREA-PHENOL-FORMALDEHYDE RESIN; (UREA EXTENDED
PHENOL-FORMALDEHYDE RESIN (CURED))
CAS:25104-55-6
Minumum % Wt:2.
Maxumum % Wt:18.
Ingred Name:NON-WOVEN, AP, FSK OR VINYL FACINGS; OR VINYL, ACRYLIC OR
LATEX COATINGS
Minumum % Wt:1.
Maxumum % Wt:40.
Ingred Name:PHENOL-FORMALDEHYDE-MELAMINE-UREA RESIN; (UREA EXTENDED
PHENOL-MELAMINE-FORMALDEHYDE RESIN (CURED))
CAS:25212-25-3
Minumum % Wt:2.
Maxumum % Wt:18.
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT DETERMINED
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: DUST FROM PROD IS MECH IRRITANT
WHICH MEANS IT MAY CAUSE IRRIT OR SCRATCHINESS OF THROAT &/OR
ITCHING IN EYES & SKIN. CHRONIC: STUDIES HAVE BEEN CONDUCTED TO
DETERM LONG-TERM EFTS OF FIBER GLAS S. RSLTS OF WORKER HLTH STUDY
THAT LOOKED AT RESP HLTH OF FIBER GLASS MFG WORKERS WERE PUB IN
1993 & RSLTS INDICATED NO LUNG DISEASE ("NO ADVERSE CLINICAL,
FUNCTIONAL OR RADIOGRAPHIC SIGNS OF EFTS"). STUDIES OF FIBER GLASS
MFG WORKERS HAVE SHOWN S EXCESS OF LUNG CANCER WHEN COMPARED TO
LOCAL CTL GROUPS. HOWEVER, THERE IS NO EVIDENCE THAT THIS EXCESS IS
RELATED TO BRTHG FIBER GLASS. FIVE PREVIOUS C HRONIC INHAL STUDIES
(SUPDAT)
Explanation of Carcinogenicity:FIBROUS GLASS: IARC MONOGRAPHS, VOL 43,
PG 152, 1988:GROUP 2B.
Effects of Overexposure:INHALATION: IRRITATION OF THE UPPER RESPIRATORY
TRACT (SCRATCHY THROAT), COUGHING AND CONGESTION MAY OCCUR IN
EXTREME EXPOSURES. SKIN: TEMPORARY IRRITATION (ITCHING) OR REDNESS
MAY OCCUR. ABSORPTION: NOT APPLICABLE. INGESTION: THIS PRODUCT IS
NOT INTENDED TO BE INGESTED OR EATING UNDER NORMAL CONDITIONS OF
USE. IF INGESTED, IT MAY CAUSE TEMPORARY IRRITATION TO THE
GASTROINTESTINAL TRACT, ESPECIALL Y THE STOMACH.
Medical Cond Aggravated by Exposure:PRE-EXISTING CHRONIC RESPIRATORY,
SKIN OR EYE DISEASES OR CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. DRINK WATER TO CLEAR THROAT &
BLOW NOSE TO REMOVE FIBERS & DUSTS. SKIN: WASH GENTLY W/SOAP & WARM
WATER TO REMOVE DUST & FIBERS. WASH HANDS BEFORE EATING OR USING
RESTROOM. INGEST: TREAT SYMPTOMATICALLY. RINSE MOUTH W/WATER TO
REMOVE FIBERS & DRINK PLENTY OF WATER TO HELP REDUCE IRRIT. NO
CHRONIC EFTS EXPECTED FOLLOWING INGEST. EYES: DO NOT RUB OR SCRATCH
EYES. DUST PAR TICLES MAY CAUSE EYE TO BE SCRATCHED. FLUSH EYES
W/LG AMTS OF WATER FOR AT LST 15 MIN. IF IRRIT PERSISTS, CNTCT MD.
NOTES TO MD: PROD IS MECH IRRITANT & IS NOT EXPECTED TO PRDCE ANY
CHRONIC HLTH EFTS FROM ACUTE EXPOS. (SUPDAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE (CO*2), WATER, WATER FOG, DRY
CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT. NO SPECIAL PROCEDURES ARE EXPECTED TO BE NECESSARY FOR
THIS PRODUCT. NORMAL FIRE FIGHTING PROCEDURRES SHOULD BE FOLLOWED
TO AVOID INHALATION OF S MOKE AND GASES.
Unusual Fire/Explosion Hazard:THERE IS NO POTENTIAL FOR FIRE OR
EXPLOSION.
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP LARGE PIECES. VACUUM DUSTS. IF
SWEEPING IS NECESSARY, USE A DUST SUPPRESSANT SUCH AS WATER. DO NOT
DRY SWEEP DUST ACCUMULATION OR USE COMPRESSED AIR TO CLEAN-UP.
THESE PROCEDURES WILL HELP TO MINIMIZE POTENTIAL EXPOSURES.
======================Handling and Storage ======================
Handling and Storage Precautions:USE PROTECTIVE EQUIPMENT AS DESCRIBED
IN MSDS WHEN HANDLING UNCONTAINED MATERIAL. WAREHOUSE STORAGE
SHOULD BE IN ACCORDANCE WITH PACKAGE DIRECTIONS, IF ANY. MATERIAL
SHOULD BE KEPT DRY AND PROTECTED F ROM THE ELEMENTS.
Other Precautions:PROT EQUIP SHOULD BE PROVIDED AS NECESSARY TO PVNT
IRRIT OF THROAT, EYES & SKIN & TO KEEP EXPOSURES BELOW APPLIC EXPOS
LIMITS. DURING REPAIR/MAINTENANCE OF CONTAM EQUIP: USE PERSONAL
PROT EQUIP AS DES CRIBED IN MSDS. WHERE POSSIBLE, VACUUM EQUIP
BEFORE REPAIR/MAINTENANCE TO REMOVE EXCESSIVE DUST & LO OSE FIBERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPRVD RESP SHOULD BE USED IF VENT IS
UNAVAIL/INADEQ FOR KEEPING DUST & FIBER LEVELS BELOW APPLIC EXPOS
LIMS. IN THOSE CASES, USE NIOSH APPRVD DISPOSABLE OR REUSABLE
PARTICULATE RESP W/EFFICIENC Y RATING OF N95 OR HIGHER (UNDER 42
CFR 84) WHEN WORKING W/PROD. FOR EXPOS UP TO 5 TIMES ESTABLISHED
EXPOS LIMS USE NIOSH APPRVD QUARTER-MASK (OTHER INFO)
Ventilation:LOC EXHST VENT @ AREAS OF CUTTING TO REMOVE AIRBORNE DUST &
FIBERS. GEN DILUTION VENT AS NEC TO KEEP AIRBORNE DUST & FIBERS
BELOW APPLIC EXPOS (ECOLOGICAL INFO)
USED.
Other Protective Equipment:LOOSE-FITTING, LONG-SLEEVED CLTHG TO PROTECT
SKIN FROM IRRIT. EXPOSED SKIN AREAS SHOULD BE WASHED W/SOAP & WARM
WATER AFTER HNDLG OR WORKING W/FIBER GLASS.
Work Hygienic Practices:CLTHG SHOULD BE WASHED SEPARATELY FROM OTHER
CLOTHES & WASHER SHOULD BE RINSED THOROUGHLY (RUN EMPTY FOR
COMPLETE WASH CYCLE). THIS WILL REDUCE CHANCES OF FIBER GLASS BEING
TRANSFERRED TO OTHER CLTHG.
Supplemental Safety and Health
FIRST AID PROC: TREATMENT SHOULD BE DIRECTED TOWARD REMOVING SOURCE OF
IRRIT W/SYPTOMATIC TREATMENT AS NEC. HLTH HAZS: EXPOSING ANIMALS
TO SPEC PURPOSE FIBER GLASS HAVE NOT SHOWN ANY EVID OF DISEASE.
EARLY DATA FROM CURRENT ONGOING CHRONIC ANIMAL INHAL STUDY HAS
SHOWN MESOTHELIOMA & FIBROSIS W/EXPOS (OTHER INFO)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NOT DETERMINED
Melt/Freeze Pt:>704.4C, ######F
Spec Gravity:VARIABLE (H*2O=1)
Solubility in Water:NIL
Appearance and Odor:GOLD-TO-YELLOW OR BLACK FIBROUS GLASS BLANKET,
BOARD OR (ECOLOGICAL INFO)
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:THIS PRODUCT IS NOT REACTIVE.
Hazardous Decomposition Products:THOSE THAT WOULD BE EXPECTED FROM ANY
ORG (CARBON-CONTAINING) MATL & ARE MAINLY DERIVED FROM PYROLYSIS,
OR BURNING OF THE RESIN. THESE DECOMP PRODS MAY INCL CARBON
DIOXIDE, CARBON (ECOLOGICAL INFO)
=================== Toxicological Information===================
Toxicological Information:PROD HAS NOT BEEN TESTED AS SEPARATE ENTITY;
HAZS MUST BE EVALUATED ON BASIS OF INDIVIDUAL INGREDS & THOSE HAZS
MUST BE ASSUMED TO BE ADDITIVE IN ABSENCE OF COMPLETE INFO. HAZS
DESCRIBED HAVE BEEN EVA LUATED BASED ON THRESHOLD OF 1.0% FOR ALL
HAZ INGREDS & 0.1% FOR ALL CARCINS. ACUTE EFTS:FIBERS FROM PROD ARE
MECH IRRITANTS & MAY CAUSE TRANSITORY IRRIT TO EXPOSED AREAS SUCH
AS EYES, SKIN & UPPER RE SP PASSAGES. CHRONIC: IN 1993, RSLTS OF
STUDY THAT LOOKED AT RESP HLTH OF FIBER GLASS MFG WORKERS
PUBLISHED. WHEN COMPARING HLTH OF WORKERS TO MEMBERS OF LOC
COMMUNITIES RESEARCHERS REPORTED, "THESE RSLTS INDICATE NO
(TRANSPORT INFO)
===================== Ecological Information =====================
Ecological:PROD HAS NOT BEEN TESTED FOR ECOTOXICITY. VENT: LIMS &
GUIDELINES. NEED FOR VENT SYS SHOULD BE EVALUATED BY PROFESSIONAL
INDUSTRIAL HYGIENIST, WHILE DESIGN OF SPECIFIC VENT SYS SHOULD BE
CONDUCTED BY PROFESSIONAL ENGINEER. APPEAR/ODOR: FORMED SHAPES
WITH OR W/OUT NON-WOVEN/VINYL FACINGS; NO SIGNIFICANT ODOR. VOC:
NOT APPLICABLE. HAZ DECOMP PRODS: MONOXIDE, CARBON PARTICLES,
FORMALDEHYDE & TRACES O F HYDROGEN CYANIDE. OTHER INFO: OUT &
SPRAYING MAY GENERATE AIRBORNE FIBER CONCS REQUIRING HIGHER LEVEL
OF RESP PROT. FOR EXPOS UP TO 50 TIMES ESTABLISHED EXPOS LIMS, USE
NIOSH APPRVD FULL-FACE RESP, RATED N99 OR HIGHER.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTES ARE NOT HAZARDOUS AS DEFINED BY RCRA 40
CFR 261. COPLY WITH FEDERAL, STATE & LOCAL REGULATIONS FOR DISPOSAL
OF FIBER GLASS WOOL PRODUCTS. IF YOU ARE UNSURE OF THE REGULATIONS,
CONTACT YOUR LOCA L PUBLIC HEALTH DEPARTMENT OR THE LOCAL OFFICE OF
THE ENVIRONMENTAL PROTECTION AGENCY (EPA).
=================== MSDS Transport Information ===================
Transport Information:U.S. DOT SHIPPING CLASSIFICATION: NOT CLASSIFIED
AS HAZ MATL. TOXICOLOGICAL INFO: ADVERSE CLINICAL, FUNCTIONAL OR
RADIOGRAPHIC SIGNS OF EFTS OF EXPOS TO MMMFS (FIBER GLASS IS MMMF)
IN THESE WORKERS."IN ADDN TO REPORTING CURRENT RSLTS,
INVESTIGATORS CONCLUDED THAT "RSLTS OF INVESTIGATION ARE CONSISTENT
W/PREVIOUSLY REPORTED CROSS-SECTIONAL STUDIES THAT HAVE FAILED TO
FIND PERSUASIVE EVID OF RESP E FTS OF MFR OF MMMF." 1990 UPDATE OF
MORTALITY STUDY OF U.S. FIBER GLASS MFG WORKERS REPORTED SM BUT
STATISTICALLY SIGNIFICANT EXCESS IN RESP CANCER AMONG WORKERS. THIS
INCR, HOWEVER, COULD NOT BE ASSO C W/EXPOS TO FIBER GLASS(SARA
REGS)
===================== Regulatory Information =====================
SARA Title III Information:THERE ARE NO CHEMS IN THIS PROD REGULATED BY
SARA 313, CERCLA OR TSCA 12(B). TRANSPORT: BECAUSE NO RELATIONSHIP
FOUND BETWEEN DOSE RESPONSE OR LENGTH OF EMPLOYENT & INCR IN CANCER
RATES. STUDY HAS BEE N EXPANDED, WHILE CONTINUING TO MONITOR
WORKERS' CANCER RATES, TO IDENTIFY & EXAMINE POSS FACTORS (EG,
SMKNG) CONTRIBUTING TO INCR IN RESP CANCER. PREVIOUS CHRONIC ANIMAL
INHAL STUDIES HAVE NOT SHOWN ANY IRREVERSIBLE DISEASE EFTS RELATED
TO BLDG INSULATION FIBER GLASS EXPOS. FIVE PREVIOUS CHRONIC INHAL
STUDIES EXPOSING ANIMALS TO SPEC PURPOSE FIBER GLASS HAVE ALSO NOT
SHOWN ANY EVID OF DISEASE. CN TCT NEHC FOR MORE INFO .
Federal Regulatory Information:OSHA PELS IDENTIFIED IN INGRED SECTION
ARE BASED UPON REVISED PELS OF 1988. OSHA HAS BEEN CHALLENGED BY
COURTS TO PROVIDE MORE INFO ABOUT ITS UPDATE PROCESS. UNTIL THESE
ISSUES ARE RESOLVED, SCHULLER WILL CONTINUE TO LIST THESE PELS.
THIS PROD & ITS COPONENTS ARE LISTED ON TSCA SUBSTANCE INVENTORY.
State Regulatory Information:CALIFORNIA PROPOSITION 65 - SUBSTANCES
KNOWN TO THE STATE TO CAUSE CANCER: GLASSWOOL FIBERS (AIRBORNE
PARTICLES OF RESPIRABLE SIZE).
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TANTALUM 10,000 UG/ML (1% W/V)
CAGE:0EK28
CAGE:0EK28
============= Composition/Information on Ingredients =============
Ingred Name:TRADE SECRET COMPONENT
Ingred Name:HYDROFLUORIC ACID, HYDROGEN FLUORIDE
CAS:7664-39-3
RTECS #:MW7875000
Other REC Limits:2.5 PPM
OSHA PEL:3 PPM
ACGIH TLV:3 PPM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: LIQUID MAY CAUSE BURNS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:BURNS, COUGHING, DIFFICULTY BREATHING, NAUSEA,
VOMITING, LOSS OF CONSCIOUSNESS.
======================= First Aid Measures =======================
First Aid:INGESTION: DON'T INDUCE VOMITING. IF CONSCIOUS GIVE WATER,
MILK/MILK OF MAGNESIA. SKIN/EYES: FLUSH W/PLENTY OF WATER FOR 15
MINS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE APPROPRIATE MEDIA FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR PROPER PROTECTIVE EQUIPMENT & SELF
CONTAINED BREATHING APPARATUS W/FULL FACEPIECE OPERATED IN POSITIVE
PRESSURE MODE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SCBA & FULL PROTECTIVE CLOTHING. STOP
LEAK IF POSSIBLE W/OUT RISK. USE WATER SPRAY TO REDUCE VAPORS. TAKE
UP W/SAND/OTHER NON-COMBUSTIBLE ABSORBENT MATERIAL & PLACE INTO
CONTAINER FOR LATER DISPO SAL. FLUSH AREA W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN CORROSION-PROOF AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED.
Ventilation:LOCAL EXHAUST/VENT HOOD.
Other Protective Equipment:LAB COAT
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Spec Gravity:1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR COLORLESS SOLUTION W/NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
ENVIRONMENTAL REGULATIONS. EPA HAZARDOUS WASTE #: CORROSIVE WASTE
D002.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MOLD RELEASE AGENTS & MOLD MAINTENANCE-2, (
CAGE:09800
CAGE:09800
============= Composition/Information on Ingredients =============
Ingred Name:ING 16:NO SPEC DUSTS ARE LISTED, APPLIC LIM FOR NUISANCE
DUSTS ARE ACGIH TLV 10 MG/M3 TDUST, OSHA PEL 15 MG/M3 (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17: TDUST, 5 MG/M3 RDUST. NO SMOKING IN AREA OF USE. DO
NOT USE IN GEN VICIN OF ARC WELD, OPEN FLAMES/HOT (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:SURF. HEAT &/OR UV RADIA MAY CAUSE FORM OF
CHLORIDES, FLUORIDES AND PHOSGENE .
RTECS #:9999999ZZ
Ingred Name:RESP PROT: DUST WHICH MAY BE GENERATED FROM PROD,
UNDERLYING PAINT, OR ABRASIVE.
RTECS #:9999999ZZ
Ingred Name:VENT: STANDARDS 1910.94, 1910.107, 1910.108.
RTECS #:9999999ZZ
Ingred Name:HEXANE. VP: 127
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: 10%
OSHA PEL:500 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:METHANE, CHLORODIFLUORO-; (CHLORODIFLUOROMETHANE). VP: 760
CAS:75-45-6
RTECS #:PA6390000
Fraction by Wt: 57%
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ozone Depleting Chemical:2
Ingred Name:VOLATILE ORGANIC COMPOUNDS
RTECS #:9999999VO
Fraction by Wt: 41%(WT)
Ingred Name:SUPP DATA: URINARY SYS. RPTS HAVE ASSOC RPTD & PRLNGD
OVEREXP TO SOLV W/PERM BRAIN & NERV SYS DAM. SYMPS OF (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:OVEREXP: HDCH, DIZZ, NAUS, & LOSS OF COORD ARE
INDICATIONS OF EXCESS EXPOS TO VAPS/SPRAY MISTS. RED & (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:ITCHING/BURN SENSATION MAY INDICATE EYE/EXCESS SKIN
EXPOS. CHLOROFLUOROCARBON (CFC) MATLS HAVE PRDCD SENSIT(ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:OF MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS & COULD
HAVE SIMILAR EFT IN HUMANS. ADRENOMIMETICS (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: (E.G., EPINEPHRINE) MAY BE CONTRAINDICATED EXCEPT
FOR LIFE-SUSTAINING USES IN HUMANS ACUTELY OR (ING 10)
RTECS #:9999999ZZ
Other REC Limits:YN/K SPECIFIED
Ingred Name:ING 9:CHRONICALLY EXPOSED TO CFC'S .
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH: REGULATIONS REGARDING POLLUTION.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: PRESS. DO NOT PUNCTURE, INCIN/EXPOS TO TREMP
ABOVE 120F. HEAT FROM SUNLIGNT, RADIATORS, STOVES, (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:HOT WATER, & OTHER HEAT SOURCES COULD CAUSE CONTR TO
BURST. DO NOT TAKE INTERNALLY. KEEP OUT OF REACH (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:OF CHILDREN. INTENTIONAL MISUSE BY DELIB CONC &
INHALING CONTENTS CAN BE HARMFUL/FATAL. USE ONLY W/ADEQ (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:VENT. AVOID BRTHG VAP/SPRAY MIST. AVOID CONT
W/SKIN/EYES. COATING MAY CNTN MATLS CLASSIFIED AS (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:NUISANCE PARTICULATES WHICH MAY BE PRESENT @ HAZ
LEVELS ONLY DURING SAND/ABRADING OF DRIED FILM. IF (ING 17)
RTECS #:9999999ZZ
Ingred Name:METHYL ETHER. VP: 760
CAS:115-10-6
RTECS #:PM4780000
Fraction by Wt: 31%
OSHA PEL:1000 PPM (MFR)
ACGIH TLV:1000 PPM (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRIT OF EYES/SKIN & RESP SYS.
MAY CAUSE NERV SYS DEPRESS. EXTREME OVEREXP MAY RSLT IN UNCON &
POSS DEATH. CHRONIC: PRLNGD & RPTD EXPOS TO HEXANE MAY CAUSE DAM TO
NERVE TISSUE OF ARMS & LEGS (PE RIPHERAL NEUROPATHY), RSLTG IN
MUSCULARWEAKNESS & LOSS OF SENSATION. EFT MAY BE INCR BY PRESENCE
OF (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:METHYL ETHYL KETONE.
TETRAFLUOROETHYLENE OVEREXP MAY CAUSE FLU-LIKE SYMP WHICH MAY INCL
FEVER, CHILLS, BACKACHE, & NUMBNESS/TINGLING OF EXTREM. INHAL OF
SMOKE/FUMES OF TETRAFLUOROETHYLENE MAY CAUSE POLYMER FUME FEVER, A
FLU-LIKE CNDTN WHICH OCCURS SEVERAL HRS AFTER EXPOS & SUBSIDES W/IN
(SUPP DATA)
Medical Cond Aggravated by Exposure:NONE GENERALLY KNOWN.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM &
QUIET. SKIN: WASH AFFECTED AREA THORO WITH SOAP AND WATER. REMOVE
CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE. EYES: FLUSH WITH
LARGE AMO UNTS OF WATER FOR AT LEAST 15 MIN. INGEST: NEVER GIVE
ANYTHING BY MOUTH TO AN UNCON PERSON. DO NOT INDUCE VOMITING. GIVE
SEVERAL GLASSES OF WATER. SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:<0F,<-18C
Lower Limits:1%
Upper Limits:12.8%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
WATER SPRAY MAY BE INEFTIVE. IF WATER IS USED, FOG NOZZ ARE PREF.
WATER MAY BE USED TO COOL CLSD (SUPP DATA)
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO
BUILD-UP OF PRESS) WHEN EXPOSED TO EXTREME HEAT. THERMAL DECOMP
PROD MAY INCL CHLORIDES, FLUORIDES & PHOSGENE .
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTENTS ARE FLAMM. KEEP AWAY FROM
HEAT/SPARKS/OPEN FLAME. VAPS WILL ACCUMULATE READILY & MAY IGNITE
EXPLOS. CONSULT NFPA CODE.
Other Precautions:DURING USE & UNTIL VAPS ARE GONE; KEEP AREA VENTD-DO
NOT SMOKE-EXTING ALL FLAMES, PILOT LIGHTS, & HEATERS-TURN OFF
STOVES, ELECTRIC TOOLS & APPLIANCES, & ANY OTHER SOURCES OF IGNIT.
USE APPRVD BOND & GROUND PROC. CONTENTS UNDER (ING 12)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIM BY VENT, WEAR A NIOSH/MSHA APPRVD PROPERLY FITTED ORG
VAP/PARTICULATE RESP FOR PROT AGAINST MATLS. WHEN SAND/ABRADING
DRIED FILM, WEAR A NIOSH/M SHA APPRVD DUST/MIST RESP FOR (ING 20)
Ventilation:LOC EXHAUST PREF. GEN EXHAUST ACCEPTABLE IF EXPOS TO MATLS
IS MAINTAINED BELOW APPLIC EXPOS LIM. REFER TO OSHA (ING 21)
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
MFR TRADE NAME/PART NO: HD PAINTABLE, 00507. FIRE FIGHT PROC: CONTRS TO
PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLOS WHEN EXPOS TO EXTREME
HEAT. EFTS OF OVEREXP:25 HRS. POLYMER FUME FEVER DOES NOT CAUS E
PERM INJURY & EFTS ARE NOT CUMULATIVE. PRLNGD OVEREXP TO SOLV
INGRED MAY CAUSE ADVERSE EFTS TO LIVER & (ING 5)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:<0-289F
Vapor Density:HVR/AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:>25
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE. CHLORIDES, FLUORIDES & PHOSGENE .
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM PROD MAY BE HAZ AS DEFINED UNDER
RESOURCE CONSERVATION & RECOVERY ACT (RCRA) 40 CFR 261. WASTE MUST
BE TESTED FOR IGNITABILITY TO DETERM APPLIC EPA HAZ WASTE NUMBERS.
DO NOT INCIN. DEPRESSU RIZE CONTR. DISPOSE OF I/A/W FED, ST &
LOC(ING 11)
| 1 | eyes_protection_mandatory |
Product ID:MNT
CAGE:53798
CAGE:53798
============= Composition/Information on Ingredients =============
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: <60%
Other REC Limits:N/K
OSHA PEL:350 PPM/450 STEL
ACGIH TLV:350 PPM/450STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 10.8%
Other REC Limits:N/K
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:BUTANE
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: <10%
Other REC Limits:N/K
OSHA PEL:800 PPM
ACGIH TLV:800 PPM; 9192
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: <20%
Other REC Limits:N/K
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9192
Ingred Name:TRIETHYLENE GLYCOL
CAS:112-27-6
RTECS #:YE4550000
Fraction by Wt: 8.0%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PROPYLENE GLYCOL
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: 0.5%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS AND SYMPTOMS OF
OVEREXPOSURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:N/K .SKIN:PROLONGED CONTACT WITH THE SKIN
MAY CAUSE DRY SKIN OR IRRITATION.INGESTION:DO NOT TAKE
INTERNALLY.SWALLOWING THIS PRODUCT COULD RESULT IN CRAMPS,VOMITING
OR DIARRHEA.INHAL:DE LIBERATE INHAL OF VAPS COULD BE HARMFUL.INHAL
MAY RESULT IN HEADACHE,NAUSEA,DIZZINESS,AND POSSIBLE RESP
IRRITATION.
Medical Cond Aggravated by Exposure:N/K
======================= First Aid Measures =======================
First Aid:EYES:FLUSH EYES WITH PLENTY OF COOL WATER FOR AT LEAST 15
MIN.CONTACT A PHYSICIAN IF IRRITATION PERSISTS.SKIN:WASH THOROUGHLY
WITH SOAP AND WATER.IF IRRITATION PERSISTS AFTER WASHING,CONSULT A
PHYSICI AN.INGESTION:CONTACT MD IMMED.CONTAINS ISOPROPYL
ALCOHOL.NOTE TO MD:1,1,1-TRICHLOROETHANE MAY CAUSE CARDIAC
IRRITABILITY.AVOID EPINEPHRINE.INHAL:REMOVE PERSON TO FRESH AIR AND
IMMED CALL A MD.
===================== Fire Fighting Measures =====================
Flash Point:POS FLAM EXT
Lower Limits:N/K
Upper Limits:N/K
Extinguishing Media:WATER FOG,FOAM,CARBON DIOXIDE,OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR PRESSURE DEMAND SCBA AND FULL PROTECTIVE
EQUIPMENT .KEEP CNTRS COOL.USE SHIELDING TO PROTECT PERSONNEL FROM
VENTING,RUPTURING OR BURSTING CANS.
Unusual Fire/Explosion Hazard:EXPOSURES TO TEMPS ABOVE 120F,48.9C MAY
CAUSE CANS TO VENT,RUPTURE OR BURST.FLAMMABLE.HAZ DECOMP PRODS MAY
INCLUDE HCL,PHOSGENE,CHLORINE AND/OR CARBON MONOXIDE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA.FLUSH WITH PLENTY OF WATER.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:FLAMMABLE.DO NOT USE OR STORE NEAR
OPEN FLAME OR WHERE TEMPS ARE >120F,48.9C.CONTENTS UNDER
PRESSURE.DO NOT PUNCTURE OR INCINERATE CANS.
Other Precautions:NO SMOKING IN AREA OF USE.DO NOT USE IN GENERAL
VICINITY OF ARC WELDING,OPEN FLAMES OR HOT SURFACES.HEAT AND/OR UV
RADIATION MAY CAUSE THE FORMATION OF HCL AND/OR PHOSGENE .AVOID
CONTACT W/ SKIN & EYES.AVOID CONTAM OF FOOD.(SEE SUPP)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Other Protective Equipment:NONE.
Work Hygienic Practices:N/K
Supplemental Safety and Health
OTHER PREC:DO NOT SPRAY DIRECTLY ON PLASTIC OR VARNISHED SURFACES.READ
AND FOLLOW ALL LABEL PRECAUTIONS BEFORE USE.FOR INDUSTRIAL USE
ONLY.KEEP OUT OF REACH OF CHILDREN.% VOLAT BY WT:100.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/K
Vapor Density:N/K
Evaporation Rate & Reference:N/K
Solubility in Water:INSOLUBLE
Appearance and Odor:A CLEAR AEROSOL SPRAY WITH A MINT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG CAUSTICS,STRONG OXIDIZERS,CHEMICALLY ACTIVE METALS SUCH AS
SODIUM,MAGNESIUM,OR POWDERED ALUMINUM.
Stability Condition to Avoid:AVOID TEMPERATURE ABOVE 120F,48.9C.
Hazardous Decomposition Products:HCL,PHOSGENE,CHLORINE,AND/OR CARBON
MONOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .DO NOT PUNCTURE OR INCINERATE
CANS.GIVE CANS TO A DISPOSAL SERVICE EQUIPPED TO SAFELY HANDLE AND
DISPOSE OF PRESSURIZED C ONTAINERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BLA031
Article:Y
Preparer's Name:FRANK E. TROJAN
CAGE:88236
CAGE:88236
============= Composition/Information on Ingredients =============
Ingred Name:PROMETHIUM 147
< Wt:1.
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE PROVIDED BY MFR.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS IS AN ARTICLE - NON HAZARDOUS.
ACUTE & CHRONIC: SIGNIFICANT EXPOSURE TO A RADIONUCLIDE MAY CAUSE
CANCER.
Explanation of Carcinogenicity:NOT LISTED IN NTP, IARC OR OSHA.
SIGNIFICANT EXPOSURE TO A RADIONUCLIDE MAY CAUSE CANCER.
Effects of Overexposure:PROMETHIUM IS A WEAK BETA EMITTER. IF EXPOSURE
IS SUSPECTED, SEEK MEDICAL ATTENTION. URINE ANALYSIS IS SUGGESTED
TO MEASURE THE DEGREE OF EXPOSURE
Medical Cond Aggravated by Exposure:HEALING OF DAMAGED TISSUE MAY BE
PROLONGED
======================= First Aid Measures =======================
First Aid:SKIN: IMMEDIATELY FLUSH WITH WATER FOR 15 MINS. EYE:
IMMEDIATELY FLUSH WITH WATER FOR 15 MINS. INHALATION: REMOVE TO
FRESH AIR. INGESTION: USE OF A CHELATING AGENT UNDER MEDICAL
SUPERVISION.
===================== Fire Fighting Measures =====================
Autoignition Temp:Autoignition Temp Text:NOT AP
Lower Limits:NOT APPLICAB
Upper Limits:NOT APPLICAB
================== Accidental Release Measures ==================
Spill Release Procedures:IF SPILLED, WEAR RADIONUCLIDE CARTRIDGE
RESPIRATOR.
Neutralizing Agent:NONE PROVIDED BY MFR.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE PROVIDED BY MFR.
Other Precautions:NONE PROVIDED BY MFR.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF SPILLED, WEAR RADIONUCLIDE CARTRIDGE
RESPIRATOR.
Ventilation:PLACED AFFECTED COMPONENT IN LOCAL EXHAUST.
Work Hygienic Practices:WASH HANDS
Supplemental Safety and Health
NONE PROVIDED BY MFR.
================== Physical/Chemical Properties ==================
HCC:A1
Boiling Pt:=1348.9C, 2460.F
B.P. Text:1 ATMOSPHERE
Melt/Freeze Pt:=1168.C, ######F
Vapor Density:NOT APPLIC
Spec Gravity:7.22
Appearance and Odor:METALLIC SOLID
Percent Volatiles by Volume:NOT APPLICAB
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CORROSIVES
Hazardous Decomposition Products:UNBOUND PROMETHIUM-147
Conditions to Avoid Polymerization:WILL NOT OCCUR
==================== Disposal Considerations ====================
Waste Disposal Methods:NONE PROVIDED BY MFR.
=================== MSDS Transport Information ===================
Transport Information:RADIOACTIVE MATERIAL, EXCEPTED PACKAGE, ARTICLES.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HYDROBROMIC ACID POTASSIUM SALT, PX1378
CAGE:DO242
CAGE:63612
CAGE:DO242
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM BROMIDE
CAS:7758-02-3
RTECS #:TS7650000
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE IRRITATION ON CONTACT WITH
SKIN, EYES OR MUCOUS MEMBRANES. DUST INHALATION MAY BE IRRITATING
TO RESPIRATORY SYSTEM. PROLONGED INHALATION CAN CAUSE BRONCHITIS.
INGESTION CAN CAUSE NAUSEA, VOM ITING AND DEPRESSION. RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO DUST. TESTS ON
LABORATORY (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:ANIMALS INDICATE MATERIAL MAY PRODUCE
ADVERSE MUTAGENIC EFFECTS.
Medical Cond Aggravated by Exposure:RESPIRATORY CONDITIONS.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ASSISTANCE FOR ALL CASES OF OVEREXPOSURE.
EYES:IMMEDIATELY FLUSH THOROUGHLY WITH WATER FOR AT LEAST 15
MINUTES. SKIN:WASH THOROUGHLY WITH SOAP AND WATER.
INHALATION:REMOVE TO FRESH AIR; GI VE ARTIFICIAL RESPIRATION IF
BREATHING HAS STOPPED. INGESTION:IF CONSCIOUS, DRINK WATER AND
INDUCE VOMITING IMMEDIATELY AS DIRECTED BY MEDICAL PERS. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCON PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONCOMBUSTIBLE
Extinguishing Media:USE ANY SUITABLE FOR ADJACENT MATERIALS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA OF ALL UNNEC PERS. WEAR SUITABLE
PROT EQUIP LISTED UNDER CTL MEASURES. ELIM ANY IGNIT SOURCES UNTIL
AREA IS DETERM TO BE FREE FROM EXPLO/FIRE HAZS. CNTN RELS & ELIM
ITS SOURCE, IF THIS C AN BE DONE W/OUT RISK. TAKE UP & (SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. STORE AT
CONTROLLED ROOM TEMPERATURE. DO NOT BREATHE DUST. DO NOT GET IN
EYES. AVOID PROLONGED OR REPEATED SKIN CONTACT.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:MATERIAL SHOULD BE HANDLED OR TRANSFERRED IN AN APPROVED
FUME HOOD OR WITH ADEQUATE VENTILATION.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. DO NOT TAKE
INTERNALLY.
Supplemental Safety and Health
SPILL PROC:CONTAINERIZE FOR PROPER DISPOSAL AS DESCRIBED UNDER
DISPOSAL. COMPLY WITH FEDERAL, STATE AND LOCAL REGULATIONS ON
PREVENT SKIN CONTACT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:2516F,1380C
Melt/Freeze Pt:M.P/F.P Text:1346F,730C
Spec Gravity:2.75 (H*2O=1)
Solubility in Water:53%
Appearance and Odor:WHITE CRYSTALS OR GRANULES, ODORLESS.
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, OXIDIZERS.
Stability Condition to Avoid:DUSTING.
Hazardous Decomposition Products:BROMINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:MATERIAL DOES NOT HAVE AN EPA WASTE NUMBER AND
IS NOT LISTED WASTE. HOWEVER CONSULTATION W/PERMITTED WASTE DISP
SITE (TSD) SHOULD BE ACCOMPLISHED. ALWAYS CONT PERMITTED TSD TO
ASSURE COMPLIANCE W/ALL CURRENT LOC, STATE & FED REGS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: A755R
Cage: HASPE
=======================================================
Contractor Summary
=======================================================
Cage: HASPE
=======================================================
Ingredients
=======================================================
Cas: 67-63-0
RTECS #: NT8050000
% Wt: <5
OSHA PEL: 400 PPM
ACGIH TLV: 400 PPM/500STEL
------------------------------
Cas: 84852-15-3
RTECS #: SM5650000
% Wt: <5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 64742-95-6
RTECS #: WF3400000
% Wt: <5
OSHA PEL: 50 PPM (MFR)
ACGIH TLV: 50 PPM (MFR)
------------------------------
Cas: 25085-99-8
% Wt: 75-90
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: SEE INGREDIENTS.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: EYES: SEVERE IRRITANT. CONTACT MAY CAUSE BLINDNESS.
SKIN: CORROSIVE. CAN CAUSE IRRITATION AND/OR BURNS ON CONTACT. INGESTION:
MODERATELY TOXIC BY INGESTION. INHALATION: VAPORS OR MISTS MAY CAUS E
IRRITATION. TARGET ORGANS: EYES, SKIN. CHRONIC: NONE.
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: CAN CAUSE BURNS TO SKIN AND EYES. VAPORS
WILL CAUSE RESPIRATORY TRACT IRRITATION. SYMPTOMS MAY INCLUDE NAUSEA,
HEADACHE, VOMITING AND DIFFICULTY BREATHING. SYMPTOMS MAY BE DELAYED.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES: FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST 15 MINUTES.
SKIN: FLUSH WITH COPIOUS AMOUNTS OF WATER. INGESTION: DO NOT INDUCE VOMITING.
IF PATIENT IS ALERT GIVE TWO OR THREE GLASSES OF WATER. GET MEDICAL
ATTENTION. INHALATION: REMOVE VICTIM TO FRESH AIR.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SML SPILL: SOAK UP W/SAND/OTHER ABSORB MATL. WEAR
TO COOL CONTRS. LGE SPILL: DIKE AREA TO CONTAIN SPILL. DO NOT ALLOW LIQ TO
ENT ER WATER/DRINKING WATER SUPPLY. PUMP (SUP DAT)
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL OF EMPTY CONTAINER/CONTAINER RINSATE: DISPOSE
OF AS A HAZARDOUS WASTE. DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS (FP N).
Handling And Storage Precautions: AVOID ALL SKIN CONTACT.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: 125F,52C
Lower Limits: 0.9%
Upper Limits: 12.1%
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). EVACUATE PERSONNEL DOWNWIND FROM THE FIRE.
Unusual Fire/Explosion Hazard: HAZARDOUS COMBUSTION PRODUCTS: CARBON MONOXIDE,
CARBON DIOXIDE, PHENOLIC COMPOUNDS.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE NEEDED UNDER NORMAL WORK CONDITIONS. IF VAPORS ARE
PRESENT, WEAR A NIOSH APPROVED FULL-FACE ORGANIC VAPOR CARTRIDGE RESPIRATOR.
Ventilation: LOCAL EXHAUST VENTILATION.
Other Protective Equipment: EMERGENCY EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: WASH AFTER HANDLING.
Supplemental Safety and Health: SPILL PROC: INTO RECOVERY DRUMS/ADD ABSORB
& PLACE IN CONTR FOR DISP. WEAR NIOSH APPRVD RESP & SKIN PROT. DO NOT
ALLOW CHEM TO ENTER SURF WATER. EYE PROT: & FULL LENGTH FACESHIELD (FP
N).
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >177F,>81C
Vapor Density: >1
Spec Gravity: 1.13 (H*2O=1)
VOC Pounds/Gallon: .58
PH: BASIC
Evaporation Rate & Reference: SLOWER THAN ETHER
Solubility in Water: INSOLUBLE
Appearance and Odor: CLEAR TO AMBER LIQUID, MILD AROMATIC ODOR
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE.
Materials To Avoid: VIOLENT REACTIONS MAY OCCUR WITH STRONG OXIDIZERS.
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE, PHENOLIC
COMPOUNDS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: A755R
Cage: HASPE
Company Name: HARRIS SPECIALTY CHEMICALS INC
Street: 8570 PHILLIPS HWY
Zipcode: 32256-8208
Label Required IND: Y
Date Of Label Review: 12/05/1996
Status Code: C
Label Date: 12/05/1996
Origination Code: G
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Severe
Contact Hazard: Severe
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE: EYES: SEVERE IRRITANT. CONTACT MAY
CAUSE BLINDNESS. SKIN: CORROSIVE. CAN CAUSE IRRITATION AND/OR BURNS ON
CONTACT. INGESTION: MODERATELY TOXIC BY INGESTION. INHALATION: VAPORS OR M
ISTS MAY CAUSE IRRITATION. TARGET ORGANS: EYES, SKIN. CHRONIC: NONE SPECIFIED
BY MANUFACTURER.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SN63 (SN63PB37) WRMAP2
Preparer's Name:ROBERT GILBERT
CAGE:0YP31
CAGE:0YP31
============= Composition/Information on Ingredients =============
Ingred Name:LEAD (SARA 313) (CERCLA)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 35-40%
OSHA PEL:SEE 1910.1025
ACGIH TLV:0.15MG/M3 DUST
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
Fraction by Wt: 60-65%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:ROSIN ACID; (ROSIN CORE SOLDER DECOMPOSITION PRODUCT AS
RESIN ACIDS COLOPHONY)
CAS:8050-09-7
Fraction by Wt: 1-3%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: WEAK, VOMIT, LOSS OF APPETITE,
CONVULSIONS, STUPOR & POSS COMA. CHRONIC: WEAK, INSOMNIA,
HYPERTENSION, SLIGHT IRRIT OF EYES, HDCH, POSS PARALYSIS. CHRONIC
OVEREXP TO LEAD MAY RSLT IN DMG TO BLO OD-FORMING, NERV, URINARY &
REPRO SYS. LEAD APPEARS ON THE NAVY OCCUP CHEM REPRO HAZ LIST.
(EFFECTS OF OVEREXPOSURE)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: SEEK CONSULTATION FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG & EXPOS
INFO . SIGNS & SYMPS OF EXPOS: DUST, VAP &/FUMES MAY BE IRRIT TO
SKIN, EYES & RESP SYS.
Medical Cond Aggravated by Exposure:LEAD AND ITS INORGANIC COMPOUNDS
ARE NEUROTOXINS WHICH MAY PRODUCE NEUROPATHY. ROSIN IS AN ALLERGEN.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH COPIOUS QUANTITIES OF WATER FOR AT LEAST 15
MINUTES. GET MEDICAL ATTENTION. SKIN: WASH WITH SOAP AND WATER.
INHALATION: REMOVE FROM EXPOSURE. GET MEDICAL ATTENTION IF
EXPERIENCING EFF ECTS OF OVEREXPOSURE. INGESTION: GET IMMEDIATE
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:DO NOT USE WATER ON FIRES WHERE MOLTEN
METAL IS PRESENT. HIGH TEMPERATURES MAY PRODUCE HEAVY METAL FUMES,
DUST AND/OR VAPOR.
================== Accidental Release Measures ==================
Spill Release Procedures:PARTICULATE MATTER SHOULD BE STORED IN DRY
CONTAINERS FOR LATER DISPOSAL. DUST MATERIAL SHOULD BE VACUUMED OR
WET SWEPT. DO NOT USE COMPRESSED AIR OR DRY SWEEPING AS A MEANS OF
CLEANING.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN DRY AREA. AVOID SKIN CONTACT.
AVOID BREATHING SMOKE DURING SOLDERING.
Other Precautions:NONE KNOWN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS SPECIFIED BY 29 CFR 1910.1025 (F) IF EXPOSURE
EXCEEDS PEL. USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN .
Ventilation:LOCAL EXHAUST: REMOVE SMOKE FROM BREATHING AREA. MECHANICAL
(GENERAL): ADEQUATE.
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
PERS CLTHG & SHOES SHOULD BE PROTECTED FROM CONTAMINATION.
Work Hygienic Practices:WASH HANDS W/SOAP & WATER AFTER HNDLG SOLDER, &
BEFORE EATING/SMKNG. DO NOT EAT, DRINK/SMOKE IN WORK AREAS.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:361F,183C
Spec Gravity:8 (H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:GRAY METAL WITH NEUTRAL ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:HIGH TEMPERATURES MAY PRODUCE METAL
FUMES, DUST AND/OR VAPORS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. CONSULT A LICENSED HAZARDOUS WASTE COMPANY.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: ACRYLIC/EPOXY WATERBORNE SEMI-GLOSS/ENAMEL, 330085 (ACRYLIC)
Cage: 3Y107
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 3Y107
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHALATION: RESIDUAL VAPORS MAY BE IRRITATING TO EYES,
SKIN MUCOUS MEMBRANES, RESPIRATORY TRACT, AND MAY PRODUCE SYMPTOMS OF
HEADACHE, NAUSEA IN POORLY VENTILATED AREAS. SKIN CONTACT: PROLONGED OR REP
EATED CONTACT WITH PAINT MAY CAUSE SKIN IRRITATION. EYE CONTACT: DIRECT
CONTACT WITH PAINT MAY RESULT IN EYE IRRITATION. THIS PRODUCT CONTAINS CHROME
OXIDE WHICH IS A STABLE CRYSTAL STRUCTURE. PROLONG ED OVEREXPOSURE TO
AIRBORNE DUSTS OF CERTAIN COMPOUNDS IS KNOWN TO CAUSE ADVERSE EFFECTS ON THE
LUNGS.
Medical Cond Aggravated By Exposure: ALLERGY OR SKIN SENSITIZATION.
First Aid: INHALATION: MOVE SUBJECT TO FRESH AIR. EYE CONTACT: FLUSH EYES WITH
PLENTY OF WATER AND CONSULT A PHYSICIAN. SKIN CONTACT: WASH SKIN THOROUGHLY
WITH SOAP AND PLENTY OF WATER. INGESTION: GIVE TWO GLASS ES OF WATER TO DRINK
AND CALL A PHYSICIAN.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: RECOVER LIQUID WITH ABSORBENT MATERIAL.
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL
REGULATIONS.
Handling And Storage Precautions: KEEP OUT OF REACH OF CHILDREN. DO NOT INGEST.
Other Precautions: AVOID PROLONGED CONTACT WITH SKIN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point: =71.1C, 160.F
Lower Limits: 0.9%
Upper Limits: 8.5%
Extinguishing Media: FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures: USE NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS
AND FULL PROTECTIVE EQUIPMENT (FP N). WATER MAY BE USED TO COOL CLOSED
CONTAINERS TO PREVENT PRESSURE BUILD-UP AND POSSIBLE EXPLOSION WHEN EXPOSED
TO EXTREME HEAT.
Unusual Fire/Explosion Hazard: CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT. CAN FORM PEROXIDES OF UNKNOWN STABILITY.
=======================================================
Control Measures
=======================================================
Respiratory Protection: A NIOSH APPROVED RESPIRATOR APPROPRIATE FOR THE
EXPOSURE OF CONCERN (FP N). IN CONFINED AREAS AND WHEN SPRAYING, USE NIOSH
APPROVED RESPIRATORY DEVICE.
Ventilation: PROPER VENTILATION.
Other Protective Equipment: EYEWASH AND DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA (FP N). NONE NEEDED UNLESS SPECIAL EQUIPMENT DESIRED.
Work Hygienic Practices: WASH HANDS AFTER USE, BEFORE EATING OR USING WASHROOM.
Supplemental Safety and Health: PHYSICAL/CHEMICAL INFORMATION (CON'T): WEIGHT
PER GALLON: 10.0. VAPOR PRESSURE: PROPYLENE GLYCOL MONOBUTYL ETHER - 0.29
MMHG @ 68F; DIETHYLENE GLYCOL MONOMETHYL ETHER - 0.20 MMHG @ 68F; ETHYLENE
GLYC OL MONO-2-ETHYLHEXEL ETHER - 17.5 MMHG @ 20C.
=======================================================
Physical/Chemical Properties
=======================================================
Boiling Point: =100.C, 212.F
Vapor Density: > AIR.
Spec Gravity: 1.0 (H2O=1)
VOC Pounds/Gallon: 1.5
VOC Grams/Liter: 166
Evaporation Rate & Reference: SLOWER THAN ETHER.
Solubility in Water: SOLUBLE.
Appearance and Odor: VISCOUS LIQUID. MILD ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: EXTREME TEMPERATURES IN CLOSED CONTAINERS.
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: CARBON DIOXIDE, CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: WILL NOT OCCUR.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: CHEMICALS SUBJECT TO THE REPORTING REQUIREMENTS OF
SECTION 313 OF THE EMERGENCY PLANNING AND COMMUNITY RIGHT-TO-KNOW ACT OF 1986
AND OF 40 CFR 372: PROPYLENE GLYCOL MONOBUTYL ETHER, DIETHYLENE GLYCOL
MONOMETHYL ETHER, AND ETHYLENE GLYCOL MONO-2-ETHYLHEXEL ETHER.
=======================================================
Other Information
=======================================================
Other Information: N/P.
=======================================================
HAZCOM Label
=======================================================
Product ID: ACRYLIC/EPOXY WATERBORNE SEMI-GLOSS/ENAMEL, 330085 (ACRYLIC)
Cage: 3Y107
Company Name: BENNETTE PAINT MANUFACTURING CO INC
Street: 401 INDUSTRY DR
Zipcode: 23661
Label Required IND: Y
Date Of Label Review: 10/19/2001
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: ACUTE: INHALATION: RESIDUAL VAPORS MAY BE IRRITATING TO
EYES, SKIN MUCOUS MEMBRANES, RESPIRATORY TRACT, AND MAY PRODUCE SYMPTOMS OF
HEADACHE, NAUSEA IN POORLY VENTILATED AREAS. EYE CONTACT: DIRECT CON TACT
WITH PAINT MAY RESULT IN EYE IRRITATION. CHRONIC: SKIN: PROLONGED OR REPEATED
CONTACT WITH PAINT MAY CAUSE SKIN IRRITATION. PROLONGED OVEREXPOSURE TO
AIRBORNE DUSTS OF CERTAIN COMPOUNDS IS KNOWNTO CAUSE ADVERSE EFFECTS ON THE
LUNGS.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PENTOTHAL SODIUM
CAGE:60060
CAGE:60060
============= Composition/Information on Ingredients =============
Ingred
Name:5-ETHYLDIHYDRO-5-(1-METHYLBUTYL)-2-THIOXO-4,6(1H,5H)-PYRIMIDIN
EDIONE MONOSODIUM SALT [THIOPENTAL SODIUM]
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS 149-600 MG/KG
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SIGNS OF CHRONIC POISONING CAN INCLUDE
RASH, FEVER, ATAXIA, CONFUSION, MALAISE, WEAKNESS & OTHER CNS
CHANGES. CAN DECREAS INTRAOCULAR PRESSURE IN MAN. AS W/OTHER
BARBITURATES, PENTOTHAL MAY BE HABIT F ORMING ALTHOUGH DRUG
DEPENDENCE IN NOT A KNOW PROBLEM.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SIGNS OF CHRONIC POISONING CAN INCLUDE RASH,
FEVER, ATAXIA, CONFUSION, MALAISE, WEAKNESS & OTHER CNS CHANGES.
CAN DECREAS INTRAOCULAR PRESSURE IN MAN. AS W/OTHER BARBITURATES,
PENTOTHAL MAY BE HABIT F ORMING ALTHOUGH DRUG DEPENDENCE IN NOT A
KNOW PROBLEM.
Medical Cond Aggravated by Exposure:MFR GAVE NO INFORMATION ON MSDS.
======================= First Aid Measures =======================
First Aid:IF PATIENT IS CONSCIOUS, INDUCE VIMITING IMMEDIATELY,
FOLLOWED BY ADMINISTRATION OF ACTIVATED CHARCOAL TO SLOW
ABSORPTION. SEEK IMMEDIATE MEDICAL ATTENTION. IF PATIENT IS NOT
CONSCIOUS, MAINTAIN ADEQU ATE RESPIRATION & SEEK IMMEDIATE MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE APPROAPRIATE MEDIA FOR UNDERLYING CAUSE OF
FIRE.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING & SELF-CONTAINED
BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:N/D
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP PROMPTLY, AVOID SKIN/EYE CONTACT.
Neutralizing Agent:MFR GAVE NO INFORMATION ON MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID EXCESSIVE TEMPERATURES & DIRECT
SUNLIGHT.
Other Precautions:MFR GAVE NO INFORMATION ON MSDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:HIGH EFFICIENCY DUST MAST (AS REQUIRED).
Ventilation:USE LOCAL VENTILATION TO CONTROL DUST AT ITS SOURCE.
Other Protective Equipment:N/D
Work Hygienic Practices:WEAR APPROPRIATE PROTECTIVE EQUIPMENT WHILE
WORKING TO CONTAIN SPILLAGE.
Supplemental Safety and Health
MFR GAVE NO INFORMATION ON MSDS.
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NONE
Melt/Freeze Pt:M.P/F.P Text:N/D
pH:>7.0
Solubility in Water:SOLUBLE IN WATER
Appearance and Odor:YELLOWISH TO WHITE, HYGROSCOPIC POWDER W/GARLIC
LIKE ODOR.
================= Stability and Reactivity Data =================
N/D
Stability Condition to Avoid:SOLUTIONS DECOMPOSE UPON STANDING.
Hazardous Decomposition Products:N/D
Conditions to Avoid Polymerization:MFR GAVE NO INFORMATION ON MSDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN AN APPROVED INCINERATOR OR ATAKE
TO A CHEMICALLY SECURE LAND DISPOSAL SITE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:POTASSIUM FERRICYANIDE (III), 99%, 208019
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:FERRATE (3-), HEXACYANO-, TRIPOTASSIUM; (POTASSIUM
FERRICYANIDE (III))
CAS:13746-66-2
RTECS #:LJ8225000
Fraction by Wt: 99%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY BE HARMFUL BY INHALATION,
INGESTION, OR SKIN ABSORPTION. MAY CAUSE IRRITATION. TO THE BEST OF
MFR KNOWLEDGE, THE CHEMICAL, PHYSICAL AND TOXICOLOGICAL PROPERTIES
HAVE NOT BEEN THOROUGHLY INV ESTIGATED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IMMED FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST
15 MINUTES. SKIN: IMMED WASH W/SOAP AND COPIOUS AMOUNTS OF WATER.
WASH CONTAMD CLTHG BEFORE REUSE. INHAL: REMOVE TO FRESH AIR. IF NOT
BRTHG GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE OXYGEN. INGEST: WASH
OUT MOUTH W/WATER PROVIDED PERSON IS CONSCIOUS. CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:NONCOMBUSTIBLE. USE EXTINGUISHING MEDIA APPROPRIATE
TO SURROUNDING FIRE CONDITIONS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH/MSHA APPROVED RESPIRATOR, CHEMICAL
IN A BAG AND HOLD FOR WASTE DISPOSAL. AVOID RAISING DUST. VENT AREA
AND WASH SPILL SITE AFTER MATERIAL PICK UP IS COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BRTHG DUST. AVOID CONT W/EYES,
SKIN & CLTHG. HARMFUL SOLID. KEEP TIGHTLY CLSD. LIGHT SENSITIVE.
AVOID CONT W/ACIDS. STORE IN A COOL DRY PLACE.
Other Precautions:A MIXT OF POTASSIUM FERRICYANIDE & SODIUM NITRITE
EXPLODES ON HEATING. MIXT OF POTASSIUM FERRICYANIDE & CHROMIUM
TRIOXIDE EXPLODE WHEN HEATED ABOVE 196C. MIXT IGNITES VIOLENTLY
WHEN GROUND W/SILVER S AND. CONT OF POTASSIUM (SUPP DATA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR IN UNVENTILATED
AREAS &/OR FOR EXPOSURE ABOVE ACGIH TLV.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH WHICH MEET ANSI
DESIGN CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
WASTE DISP METH: ANY HEAVY METALS BY ADDN OF SULFIDE & ISOLATE FOR
BURIAL. ADDNL EQUIV OF HYPOCHLORITE MAY BE NEEDED IF RXN SHOULD BE
CARRIED OUT UNDER NITROGEN. OBSERVE ALL FED, ST & LOC ENVIRON REGS
. OTHER PREC: FERRICYANIDE W/AMMONIA CAN BE EXPLO DUE TO RAPID
OXIDATION OF AMMONIA.
================== Physical/Chemical Properties ==================
Spec Gravity:1.850
Appearance and Odor:ORANGE CRYSTALS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, STRONG OXIDIZING AGENTS. MAY DISCOLOR ON EXPOSURE TO
LIGHT.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
NITROGEN OXIDES, HYDROGEN CYANIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:TREAT A DILUTE BASIC SOLN (PH 10-11) OF MATL W/A
50% EXCESS OF COMMERICAL LAUNDRY BLEACH. CTL TEMP BY ADDN RATE OF
BLEACH & ADJUST PH IF NEC. VIGOROUS EVOLUTION OF GAS MAY OCCUR.
FILTER ANY SOLIDS FOR BURIAL IN A CHEM LANDFILL.
PRECIPITATE(SUPDAT)
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: COPPER RED IRON OXIDE, R-2199
Cage: GO125
=======================================================
Contractor Summary
=======================================================
Cage: GO125
=======================================================
Ingredients
=======================================================
Cas: 1332-37-2
RTECS #: NO7380000
% Wt: >92
OSHA PEL: N/K (FP N)
ACGIH TLV: 5 MG/M3 (MFR)
------------------------------
Cas: 1317-61-9
% Wt: <8
OSHA PEL: 10 MG/M3
ACGIH TLV: 5 MG/M3
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: MAY CAUSE MECH SKIN & EYE IRRIT. RPTD &
PRLNG EXPOS TO IRON OXIDE DUST MAY CAUSE BENIGN PNEUMOCONIOSIS CALLED
SIDEROSIS. CHRONIC: PRLNG INHAL OF IRON OXIDE DUST IS KNOWN TO PRDCE A CNDTN
KNOWN AS SIDEROSIS. ON X-RAYS IT APPEARS TO BE A BENIGN PNEUMOCONIOSIS &
IS NOT ASSOC W/PULM FIBROSIS OR (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: DISABILITY UNLESS THERE IS
CONCURRENT EXPOS TO OTHER FIBROSIS-PRODUCING MATLS SUCH AS SILICA. TLV IS SET
TO PROTECT AGAINST SIDEROSIS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES: FLUSH WITH GENEROUS AMOUNTS OF WATER FOR AT LEAST 15 MINUTES.
CALL MD IF IRRITATION PERSISTS. SKIN: WASH WITH MILD SOAP AND WATER.
INHALATION: REMOVE TO FRESH AIR. CALL MD. INGESTION: IF CONSCIO US, GIVE
LARGE QUANTITIES OF WATER TO INDUCE VOMITING. GET MEDICAL ATTENTION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: VACCUM OR USE WET CLEAN-UP TECHNIQUES AND PLACE WASTE
MATERIAL IN CLOSED CONTAINER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL MUST BE MADE IN ACCORDANCE WITH FEDERAL, STATE
AND LOCAL REGULATIONS. PURSUANT TO 40 CFR PART 261 OF THE RCRA. REGULATIONS
CURRENTLY IN EFFECT, DISCARDED IRON OXIDE WOULD NOT BE CLASSIFIED AS
HAZARDOUS WASTE.
Handling And Storage Precautions: FOR TRANSPORTATION EMERGENCIES, CALL
CHEMTREC, 24 HOUR INFORMATION SERVICE, (800) 424-9300.
Other Precautions: AVOID BREATHING DUST. KEEP AWAY FROM FOOD PRODUCTS. KEEP
CONTAINER CLOSED WHEN NOT IN USE. USE WITH ADEQUATE, LOCALIZED VENTILATION.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NOT FLAMMABLE
Extinguishing Media: NOT FLAMMABLE. USE APPROPRIATE EXTINGUISHING MEDIA FOR THE
COMBUSTIBLE MATERIAL INVOLVED IN THE FIRE.
Fire Fighting Procedures: WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE OF NIOSH APPROVED DUST RESPIRATORS IS RECOMMENDED
WHEN EXPOSURE LIMITS MAY BE EXCEEDED.
Ventilation: LOCAL EXHAUST VENTILATION TO COLLECTOR OR CONTAINMENT RECOMMENDED
TO CONTROL DUST TO BELOW EXPOSURE LIMITS.
Other Protective Equipment: EMERGENCY EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: I/A/W GOOD INDUS HYGIENE PRACT, AVOID CONT W/SKIN,
EYES/CLTHG. WASH THORO AFTER HNDLG & BEFORE EATING, (SUP DAT)
Supplemental Safety and Health: HYGIENE PRACT: DRINKING/USING TOBACCO PRODUCTS.
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 4.03 (H*2O=1)
Solubility in Water: INSOLUBLE
Appearance and Odor: RED POWDER, NO ODOR
Percent Volatiles by Volume: 0
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE.
Materials To Avoid: IT IS INCOMPATIBLE WITH HYDRAZINE, CALCIUM HYPOCHLORITE,
PERFORMIC ACID, AND BROMINE PENTAFLUORIDE.
Hazardous Decomposition Products: NONE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: COPPER RED IRON OXIDE, R-2199
Cage: GO125
Assigned IND: Y
Company Name: HARCROS PIGMENTS INC
Street: 1525 WOOD AVE
Zipcode: 18042
Label Required IND: Y
Date Of Label Review: 10/21/1997
Status Code: C
Label Date: 10/21/1997
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: MAY CAUSE MECHANICAL SKIN AND EYE IRRITATION.
REPEATED AND PROLONGED EXPOSURE TO IRON OXIDE DUST MAY CAUSE BENIGN
PNEUMOCONIOSIS CALLED SIDEROSIS. CHRONIC: PROLONGED INHALATION OF IRON OXIDE
DU ST IS KNOWN TO PRODUCE A CONDITION KNOWN AS SIDEROSIS. ON X-RAYS IT
APPEARS TO BE A BENIGN PNEUMOCONIOSIS AND IS NOT ASSOCIATED WITH PULMONARY
FIBROSIS OR DISABILITY UNLESS THERE IS CONCURRENT EXPOSUR E TO OTHER
FIBROSIS-PRODUCING MATERIALS SUCH AS SILICA. THE TLV IS SET TO PROTECT
AGAINST SIDEROSIS.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:81OL TONER
CAGE:89431
CAGE:89431
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE ACRYLIC COPOLYMER *93-4*
CAS:25036-16-2
Fraction by Wt: 45-50%
Ingred Name:MAGNETITE, MAGNETIC OXIDE
CAS:1309-38-2
RTECS #:OM4800000
Fraction by Wt: 40-45%
Ingred Name:METAL COMPLEX AZO DYE
Fraction by Wt: 1-5%
Ingred Name:POLYPROPYLENE
Fraction by Wt: 1-5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION TO RESPIRATORY TRACT & EYES
MAY OCCUR IN HEAVY DUST CONDITIONS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE. SKIN: WASH W/SOAP. EYES:
FLUSH W/WATER. INGESTION: DRINK WATER. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL, CO
Fire Fighting Procedures:AVOID INHALATION OF SMOKE. WEAR MSHA/NIOSH
SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED CONTAINER
W/WATER SPRAY.
Unusual Fire/Explosion Hazard:MATERIAL CAN FORM EXPLOSIVE MIXTURES WHEN
SUSPENDED IN AIR. ALL IGNITION SOURCES SHOULD BE AVOIDED.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM/SWEEP UP AS W/ANY NON-TOXIC POWDER.
======================Handling and Storage ======================
REQUIRED FOR BULK HANDLING. DON'T STORE NEXT TO STRONG OXIDIZERS.
Other Precautions:AVOID EXCESSIVE EXPOSURE TO HEAT. AVOID BREATHING
DUST IF SPILLED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHERE USED AS INTENDED
Ventilation:MECHANICAL (GENERAL), LOCAL EXHAUST: NORMAL OFFICE
CONDITIONS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text: 275F
Spec Gravity:1.6
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK POWDER W/PAINT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:OPEN FLAME, HEAT
Hazardous Decomposition Products:TOXIC PRODUCTS OF COMBUSTION
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:5109, AD79M, AA18, FAIRING STRIPS
CAGE:96780
CAGE:96780
============= Composition/Information on Ingredients =============
Ingred Name:LEAD TETROXIDE; (LEAD OXIDE)
CAS:1314-41-6
RTECS #:OG5425000
Fraction by Wt: 9.3%
OSHA PEL:0.05 MG/M3
ACGIH TLV:0.15 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NOT APPLICABLE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NOT APPLICABLE.
Medical Cond Aggravated by Exposure:ITCHY SKIN.
======================= First Aid Measures =======================
First Aid:SKIN: WASH ANY AFFECTED AREA. EYES: FLUSH WITH WATER FOR AT
LEAST 15 MINUTES . INGESTION: CALL MD IMMEDIATELY . INHALATION:
REMOVE FROM EXPOSURE. SUPPORT BREATHING (GIVE ARTIFICIAL RESPIRA
TION/OXYGEN) .
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, FOG, FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:NOT APPLICABLE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL DRY AREA.
Other Precautions:NOT APPLICABLE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AND FACE PRIOR TO EATING, DRINKING,
OR SMOKING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:1.448
Solubility in Water:NEGLIGIBLE
Appearance and Odor:RUBBER PRODUCT WITH CHARACTERISTIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:EXTREME TEMPERATURES.
Hazardous Decomposition Products:NORMAL HYDROCARBON COMBUSTION
PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:RM 325 HIGH TEMP VALVE STEM PACKING
CAGE:0DCP7
CAGE:6Z800
CAGE:0DCP7
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9293
Ingred Name:GRAPHITE,SYNTHETIC
CAS:7782-60-7
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10MG/M3
ACGIH TLV:2 MG/M3 TOTAL DUST
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:LONG TERM EXPOSURE TO ASBESTOS FIBERS
CAN RESULT IN ASBESTOSIS AND LUNG CANCER. NO SIGNS OR SYMPTOMS OF
EXPOSURE ARE SEEN UNDER NORMAL CONDITIONS. HOWEVER, IRRITATION TO
EYES, NOSE, THROAT, SKIN AND U PPER RESPIRATORY SYSTEM WHEN EXPOSED
TODUST, WELDING FUMES AND GASES.
Explanation of Carcinogenicity:ASBESTOS IS A KNOWN HUMAN CARCINOGEN.
Effects of Overexposure:METALLIC TASTE IN MOUTH, NAUSEA, TIGHTNESS OF
CHEST, FEVER, IRRITATION TO EYES, NOSE AND THROAT CAN RESULT.
Medical Cond Aggravated by Exposure:ASTHMA, EMPHYSEMA, CHRONIC LUNG AND
RESPIRATORY DISEASES, AS WELL AS DERMATITIS AND OTHER PRE-EXISTING
CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.IF
IRRITATION PERSIST, GET MEDICAL ATTENTION. SKIN: WASH WITH MILD
SOAP AND WATER. IF IRRITATION DEVELOPS, GET MEDICAL ATTENTION.
INHALATION: M OVE VICTIM TO FRESH AIR. IF BREATHING IS DIFFICULT,
GIVE OXYGEN. SEEK MEDICAL ATTENTION. INGESTION IS UNLIKELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE WATER SPRAY, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL FROM
AREA. WEAR SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE
EQUIPMENT.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM THE MATERIAL WITH A HEPA FILTERED
VACUUM. THE EQUIPMENT SHALL BE USED & EMPTIED SO AS TO MINIMIZE THE
RE-ENTRY OF ASBESTOS INTO THE WORKPLACE. OTHERWISE, WET THE
MATERIAL WITH WATER & SURFACTAN T AND THEN SHOVEL OR MOP UP
CONTAMINATION.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE STATED BY THE MANUFACTURER.
Other Precautions:NONE STATED BY THE MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED HEPA RESPIRATOR IF
REQUIRED. WEAR SELF-CONTAINED BREATHING APPARATUS IF REQUIRED FOR
HIGH LEVELS OF CONTAMINATES.
Ventilation:LOCAL EXHAUST SUFFICIENT TO REMOVE DUST OR FUMES GENERATED.
Other Protective Equipment:USE CLOTHING SUFFICIENT TO PREVENT SKIN
CONTACT FROM DUST/FUMES AS NEEDED.
Work Hygienic Practices:AVOID CREATING DUST. FOLLOW GOOD INDUSTRIAL
HOUSEKEEPING AND PERSONAL HYGIENE PRACTICES.
Supplemental Safety and Health
ALL LISTED COMPONENTS ARE PHYSICALLY BOUND AND/OR ENCAPSULATED DURING
MANUFACTURING PROCESS AND POSE NO HEALTH OR SAFETY HAZARD WHEN USED
AND HANDLED APPROPRIATELY IN ACCORDANCE WITH GOOD INDUSTRIAL H
YGIENE AND APPROPRIATE END USE APPLICATIONS.
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:DARK GREY SOLID, SLIPPERY TO TOUCH.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, AND
OTHER POSSIBLE TOXIC DECOMPOSITIONFUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:WET THE MATERIAL WITH WATER AND SURFACTANT.
PLACE IN 6 MIL THICK POLYETHYLENE PLASTIC BAG. PLACE THESE BAGS
INTO ANOTHER POLY BAG OR A SAFE PLACE UNTIL IT CAN BE SHIPPED TO AN
APPROVED DISPOSAL SITE. IDENTIFY WITH ASBESTOS CANCER WARNING
LABEL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:UNKNOWN BRAKE BAND ASSEMBLY
Preparer's Name:DGSC-SSH
CAGE:JO772
CAGE:16236
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE:MINOR EYS/SKIN IRRITATION.
INGESTION- IRRITATION OF GI TRACT. INHALATION-IRRITATION OF
RESPIRATORY TRACT. CHRONIC: ASBESTOSIS, LUNG CANCER, &
MESOTHELIOMA, ALL OF WHICH ARE DISABLING AND FATAL D ISEASES OF THE
LUNG. INHALATION AND INGESTION OF ASBESTOS FIBERS MAY CAUSE CANCER
OF THE BOWEL.
Explanation of Carcinogenicity:CONTAINS A [1332-21-4] WHICH IS
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:INHALATION: FATIGUE AND SHORTNESS OF BREATH
THAT GETS WORSE WITH TIME AND EVENTUALLY BECOMES DISABLING. EYES:
IRRITATION. SKIN: IRRITATION. INGESTION: MILD STOMACH DISTRESS.
DIARRHEA, VOMITING, AND NA USEA.
Medical Cond Aggravated by Exposure:ASTHMA, EMPHYSEMA, AND TUBERCULOSIS
ARE ALL GENERALLY AGGRAVATED BY EXPOSURE TO ASBESTOS FIBERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SEE DOCTOR. EYES: RINSE
THOROUGHLY WITH WATER FOR 15 MINUTES. SEE DOCTOR. SKIN: WASH
THOROUGHLY WITH SOAP AND WATER. IF IRRITATION PERSISTS, SEE DOCTOR.
INGESTION: DIL UTE WITH WATER. DO NOT INDUCE VOMITING.SEE DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:NONFLAMMABLE. USE WATER FOG, CARBON DIOXIDE, FOAM,
OR DRY CHEMICAL AS REQUIRED FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM THE MATERIAL WITH A HEPA FILTERED
VACUUM. THE EQUIPMENT SHALL BE USED & EMPTIED SO AS TO MINIMIZE THE
RE- ENTRY OF ASBESTOS INTO THE WORKPLACE. OTHERWISE, WET THE
MATERIAL WITH WATER & SURFACTA NT AND THEN SHOVEL OR MOP UP
CONTAMINATION.
======================Handling and Storage ======================
Handling and Storage Precautions:ITEM IS NONFRIABLE & WILL NOT SHED
FIBERS IN NORMAL USE AND STORAGE. USED ITEMS SHALL BE WETTED
BEFORE, DURING & AFTER DISASSEMBLY.
Other Precautions:IF IT IS NECESSARY TO CUT OR IMPACT THE ITEM WHILE
INSTALLING IT, WEAR A RESPIRATOR AND PROTECTIVE CLOTHING. USED
ITEMS SHALL BE IDENTIFIED AND DISPOSED OF IN ACCORDANCE WITH ALL
LOCAL, STATE AND FEDE RAL REGULATIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED HEPA RESPIRATOR IF
REQUIRED. WEAR SELF-CONTAINED BREATHING APPARATUS IF REQUIRED FOR
HIGH LEVELS OF CONTAMINATES.
Ventilation:LOCAL EXHAUST SUFFICIENT TO ENTRAIN ALL PARTICULATE
EMISSIONS. HEPA FILTER REQUIRED. NO LEAKS ON PRESSURE SIDE OF FAN.
Other Protective Equipment:USE COVERALLS OR DISPOSABLE CLOTHING.
Work Hygienic Practices:WET WORK TO THE DEGREE POSSIBLE. WASH HANDS
AFTER HANDLING ITEM. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
MSDS GENERATED BY HMIS TECHNICIAN. MANUFACTURER IS UNKNOWN OR OUT OF
BUSINESS. ITEM ASSUMED TO CONTAIN ASBESTOS BASED ON AVAILABLE
INFORMATION.
================== Physical/Chemical Properties ==================
HCC:T6
Solubility in Water:INSOLUBLE
Appearance and Odor:DRY, MOLDED
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG MINERAL ACIDS, AND STRONG ALKALIS
Stability Condition to Avoid:ACCUMULATIONS OF DUST
Hazardous Decomposition Products:ASBESTOS DUST
==================== Disposal Considerations ====================
Waste Disposal Methods:WET THE MATERIAL WITH WATER AND SURFACTANT.
PLACE IN 6 MIL THICK POLYETHYLENE PLASTIC BAG. PLACE THESE BAGS
INTO ANOTHER POLY BAG OR A SAFE PLACE UNTIL IT CAN BE SHIPPED TO AN
APPROVED DISPOSAL SITE. IDENTIFY WITH ASBESTOS CANCER WARNING
LABEL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:THIOKOL MC-275 BASE
Kit Part:Y
CAGE:KO006
CAGE:KO006
CAGE:32063
============= Composition/Information on Ingredients =============
Ingred Name:LIMESTONE/CALCIUM CARBONATE (OSHA PEL: 15 MG/M3 TOTAL
PARTICULATE)
CAS:471-34-1
RTECS #:FF9335000
Fraction by Wt: 30-60%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 RESP FRACT
ACGIH TLV:10 MG/M3 TOTAL PART
Ingred Name:TITANIUM DIOXIDE (OSHA PEL: 10 MG/M3 TOTAL PARTICULATE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 RESP FRACT
ACGIH TLV:10 MG/M3 TOTAL PART
Ingred Name:QUARTZ (CRYSTALLINE SILICA)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 0.34%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG/M3 RESP FRACT
ACGIH TLV:0.1 MG/M3 RESP FRACT
Ingred Name:FORMALDEHYDE (SARA III) (OSHA: 0.5 MG/M3 ACTION LEVEL)
(ORAL,RAT; LD50: 800 MG/KG; INHAL,RAT; LC50: 590 MG/M3)
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: <0.1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.75 PPM; STEL 2 PPM
ACGIH TLV:1 PPM; STEL 2 PPM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:EYE:MECHANICAL IRRIT. INGEST:NAUSEA,
VOMITING, GASTROINTESTINAL UPSET. DEPENDING ON ROUTE/FREQUENCY &
DURATION OF EXPOSURE. TOXICITY MAY EFFECT IN FOLLOWING ORGANS &/OR
SYSTEMS:RESPIRATORY SYSTEM AND EYES.
Explanation of Carcinogenicity:QUARTZ-CRYSTALLINE SILICA-(IARC) AND
FORMALDEHYDE (ACGIH, NTP, & OSHA) ARE LISTED AS CARCINOGENS.
Medical Cond Aggravated by Exposure:SOME COMPONENTS IN PRODUCT MAY
AGGRAVATE EXISTING MEDICAL CONDITIONS. INDIVIDUALS WITH MEDICAL
CONDITIONS INVOLVING FOLLOWING ORGANS/SYSTEMS SHOULD TAKE
PRECAUTIONS WHEN HANDLING: RESPIRATORY SYSTEM.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WATER 15 MIN. IF IRRIT,SEE DR. SKIN: REMOVE
CONTAM CLOTH & SHOES. WASH W/SOAP & WATER. IF IRRIT,SEE DR. WASH
CONTAM CLOTH BEFORE REUSE. INHAL:REMOVE TO FRESH AIR. IF SYMPTOMS
DEVELOP,GET M ED AID. IF NO BREATH,GIVE ARTIF RESP (MOUTH TO
MOUTH). INGEST:GET MED AID.INDUCE VOMIT UNLESS ADVISED AGAINST BY
DR (IPECAC/FINGER DOWN THROAT).NOTHING BY MOUTH IF
DROWSY,UNCONSCIOUS,NO GAG REFLEX. *
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>200F,>93C
Extinguishing Media:USE AGENTS APPROVED FOR CLASS A HAZARD (E.G.
HALOGENATED AGENTS, FOAM, STEAM) OR WATER FOG.
Fire Fighting Procedures:FIREFIGHTERS & OTHERS WHO MAY BE EXPOSED TO
THE PRODUCTS OF COMBUSTION SHOULD BE EQUIPPED WITH NIOSH APPROVED
POSITIVE PRESSURE SCBA & FULL PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:SHOVEL OR VACUUM SPILLED PRODUCT AND PLACE IN
CLOSED CONTAINERS FOR FURTHER HANDLING AND DISPOSAL. DO NOT FLUSH
TO SEWER, STREAM, OR OTHER BODIES OF WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, WELL VENTILATED
AREA. NO SPECIAL PRECAUTIONS ARE NEEDED. FOLLOW GOOD MANUFACTURING
AND HANDLING PRACTICES.
Other Precautions:THIS CONTAINER CAN BE HAZARDOUS WHEN EMPTY, BECAUSE
IT CAN RETAIN PRODUCT RESIDUES. THEREFORE, DO NOT REUSE CONTAINER
FOR FOOD, CLOTHING, OR PRODUCTS FOR HUMAN OR ANIMAL CONSUMPTION OR
WHERE CONTACT M AY OCCUR.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA EQUIP (ABOVE TLV).DETERMINE TYPE FOR
SPECIFIC APPLICATION BY CONSULTING RESPRTR MFR.OBSERVE RESPIRATOR
USE LIMITS.HIGH CONCENTRATIONS MAY NEED USE OF SCBA/SUPPLIED AIR
RESPIRATOR. RESP PROT ECT PROGRAMS IN COMPLY W/29 CFR1910.134.
Ventilation:GENERAL (DILUTION) MAY BE ACCEPTABLE, HOWEVER, LOCAL
RECOMMENDED WHEN VAPORS, MISTS, OR DUSTS CAN BE RELEASED.
Other Protective Equipment:WEAR PROTECTIVE CLOTHING.
Work Hygienic Practices:WASH AFTER HANDLING,BEFORE
EATING,DRINKING,SMOKING,USING RESTROOM.WASH CONTAM GEAR,LAUNDER
CONTAM CLOTH, DISCARD SHOES.
Supplemental Safety and Health
* NOTE TO PHYSICIAN: TREATMENT SHOULD BE DIRECTED AT PREVENTING
ABSORPTION, ADMINISTERING TO THE SYMPTOMS AS THEY OCCUR, AND
PROVIDING SUPPORTIVE: THERAPY.
================== Physical/Chemical Properties ==================
Spec Gravity:1.61
Solubility in Water:INSOLUBLE
Appearance and Odor:LIGHT COLORED OFF-WHITE PASTE; SULFIDE ODOR.
Percent Volatiles by Volume:97
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING ATENTS.
Hazardous Decomposition Products:HEATED TO HIGH TEMPERATURE:PHENOLICS,
OXIDES OF SULFUR, SMOKE, SOOT, TOXIC FUMES (E.G. CARBON DIOXIDE &
CARBON MONOXIDE)
==================== Disposal Considerations ====================
Waste Disposal Methods:IF DISCARDED IN ORIGINAL FORM, MANAGE
(STORE/TREAT/DISPOSE/ETC) AT FACILITY IN COMPLY W/FED, STATE, LOCAL
REQ'MNTS (SEE GOVERNMNT ENVIRONMNTL AGENCIES FOR MORE INFO).
RECYCLE OR REWORK IF FEASIBLE;INC INERATE AT FACILITY;OR TREAT AT
TREAMNTFACILITY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:808 5508 FLEXICOLOR ELECTROSILVER FIXER & REPLENISHER, CONC
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 45-50%
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMMONIUM THIOSULFATE
CAS:7783-18-8
RTECS #:XN6465000
Fraction by Wt: 35-40%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM SULFITE
CAS:7757-83-7
RTECS #:WE2150000
Fraction by Wt: 10-15%
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMMONIUM SULFITE (CERCLA)
CAS:10196-04-0
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PENIETIC ACID, PENTA SODIUM SALT
CAS:140-01-2
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): NOT GIVEN
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. MAY CAUSE TRANSIENT EYE IRRITATION. LOW
SKIN CONTACT HAZARD FOR RECOMMENDED HANDLING. EXPECTED TO BE A LOW
INGESTION HAZARD.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMEEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY PRODUCE
HAZARDOUS DECOMPOSTION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:MAY REQUIRE NEUTRALIZATION. FLUSH TO SEWER IF
ALLOWABLE WITH LARGE AMOUNTS OF WATER. OTHERWISE, ABSORB SPILL WITH
VERMICULITE OR OTHER INERT MATERIAL, THEN PLACE IN A CONTAINER FOR
CHEMICAL WASTE. CLE AN SURFACE TO REMOVE RESIDUAL CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION. WASH
THOROUGHLY AFTER HANDLING. KEEP FROM CONTACT WITH OXIDIZING
MATERIALS. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:KEEP AWAY FROM INCOMPATIBLE MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.34
pH:8.0
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID, AMMONIA ODOR
Percent Volatiles by Volume:45-50%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BASES, SODIUM HYPOCHLORITE (BLEACH), STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:AMMONIA, SULFUR DIOXIDE, CHLORAMINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. DISPOSE OF IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:021, HAI-KPX
CAGE:49076
CAGE:49076
============= Composition/Information on Ingredients =============
Ingred Name:CHROMIUM (SARA III)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 8%
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 92%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:VENT: IN INGREDIENTS BY USE OF ADEQUATE EXHAUST
VENTILATION.
RTECS #:9999999ZZ
Ingred Name:OTHER PROT EQUIP: AWS PUBLICATION F2.2.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:UNDER NORMAL HNDLG & USE,EXPOS TO
SOLID,MASS FORMS OF ALLOY PRESENTS FEW HLTH HAZ.THEY MAY INCL SKIN
IRRIT/OTHER ALLERGIC RXNS IN SENSIT INDIV. (ACUTE)EXPOS TO DUST,
WELDING FUMES,& GASES MAY CAUSE NA US, TIGHTNESS OF CHEST,FEVER,
IRRIT OF EYES, NOSE, THROAT & SKIN; LOSS OF CONSCIOUSNESS DUE TO
WELDING (EFTS OF OVEREXP)
Explanation of Carcinogenicity:CHROMIUM: GROUP 1 (IARC), KNOWN
CARCINOGEN (NTP). NICKEL: GROUP 1 (IARC), ANTICIPATED TO BE
CARCINOGEN (NTP).
Effects of Overexposure:HLTH HAZ:GASES/LACK OF O2.(CHRONIC) ADVERSE
EFTS MAY INCL SKIN SENSIT,NEURO DMG & RESP DISEASES (BRONCH
ASTHMA,LUNG FIBROSIS/PNEUM). ACCD TO OSHA 29CFR1910.1200 NICKEL &
CHROMIUM ARE CONSIDERED POSS C ARCIN.RECENT EPIDEMIOLOGICAL STUDIES
OFWORKERS MELTING & WORKING ALLOYS CONTAINING NICKEL-CHROMIUM HAVE
FOUND (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE AND OBTAIN PROMPT MEDICAL
ATTENTION. ADMINISTER OXYGEN IF VICTIM IS UNCONSCIOUS. IF NOT
BREATHING, RESUSCITATE IMMEDIATELY. INGESTION: CALL MD IMMEDIATELY
. SKIN : FLUSH WITH COPIOUS AMOUNTS OF WATER . EYES: FLUSH WITH
WATER FOR AT LEAST 15 MINUTES.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE CONDITIONS
.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MATERIAL IS NONFLAMMABLE; HOWEVER,
WELDING ARCS AND SPARKS CAN IGNITE FLAMMABLE LIQUIDS AND VAPORS AND
COMBUSTIBLE SOLIDS.
================== Accidental Release Measures ==================
Spill Release Procedures:UNDER NORM HNDLG & USES MATL IS NOT VOLAT/
DUSTY & DOES NOT PRESENT SPILLAGE & LEAKAGE PROBLEMS. NO PROT REQD,
EXCEPT AVOID PRLNGD/RPTD DIRECT SKIN CONT IF SENSIT TO METALS. USE
(SUPDAT
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:MATERIAL IN SOLID FORM DOES NOT
REQUIRE SPECIAL PRECAUTIONS IN HANDLING AND STORING.
Other Precautions:USE INDUSTRIAL HYGIENE AIR MONITORING TO ENSURE THAT
USE OF MATERIAL DOES NOT CREATE EXPOSURES WHICH EXCEED LEVELS
SPECIFIED IN INGREDIENTS AND REACTIVITY SECTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF SOLID METAL ALLOYS ARE CONVERTED IN MFG(INCL
GRINDING, HIGH TEMP CUTTING & WELDING) PROCESSES TO DUSTS,FUMES,
GASES/ MISTS,& VENT IS NOT ADEQ TO MAINTAIN EXPOS BELOW LIMITS
SPECIFIED IN INGREDS, TH EN RESP PROT SHOULD BE USED. USE (SUPDAT
Ventilation:IF SOLID METAL ALLOYS ARE CONVERTED TO DUSTS,FUMES/MISTS,
MAINTAIN WORKING ENVIRON BELOW EXPOS LIMITS SPECIFIED (ING 3)
FACE PROT & FLAME RETARDANT CLTHG. SELECT WELDING LENSE SHADE FROM
(ING 4)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HAZ DECOMP PRODS: OXIDES OF METALS, CHROMATES, FLUORIDES & COMPLEX
METALLICS. GASES MAY INCL CO2, OZONE & NOX. SPILL PROC: WELDING
OPER, VACUUM RESIDUE INTO SUITABLE CNTNRS & DISP OF I/A/W EPA/LOC
REG S. RESP PROT: ONLY NIOSH/MSHA APPRVD RESP I/A/W OSHA
19CFR1910.134. EFTS OF OVEREXP: NO INCR RISK OF CANCER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:4982F,2750C
Melt/Freeze Pt:M.P/F.P Text:2597F,1425C
Spec Gravity:8.7
Solubility in Water:0
Appearance and Odor:GREY METALLIC; ODORLESS; SOLID METAL SHAPED AS
WIRE, ROD OR STRIP.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID ACIDS. CONTACT WITH MINERAL ACIDS WILL RELEASE HYDROGEN-A VERY
READILY COMBUSTIBLE GAS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:FUMES & GASES FROM WELDING & HIGH TEMP
CUTTING CONTAIN CONSTITUENTS DIFFERENT FROM INGREDS LISTED & MAY
INCL (SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
=======================================================
NIIN: 00-491-7197
Product ID: EMGARD 2810-A ARTIC 0W30 ENGINE OIL
Cage: TO539
=======================================================
Item Description Information
=======================================================
Item Manager: S9G
Item Name: LUBRICATING OIL,ENGINE
Specification Number: MIL-L-46167
Type/Grade/Class: NONE
Unit of Issue: DR
Quantitative Expression: 00000000055GL
UI Container Qty: 0
Type of Container: 1A1 18/18GAGE
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NO DATA PROVIDED BY MANUFACTURER
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: SKIN: SIMILAR MATERIALS ARE NOT CLASSIFIED AS SKIN
IRRITANTS. THE SKIN IRRITATION SCORE FOR THIS SUBSTANCE HAS NOT BEEN
DETERMINED. EYE: SIMILAR MATERIALS ARE NOT CLASSIFIED AS EYE IRRITANTS. THE
EYE IRRITATION SCORE FOR THIS SUBSTANCE HAS NOT BEEN DETERMINED. INHALATION:
INHALATION OF MIST MAY CAUSE IRRITATION OF THE RESPIRATORY SYSTEM. INGESTION:
SIMILAR MATERIALS ARE NOT CONSIDERED TOXIC. CHRO NIC: NONE KNOWN. NO
EFFECTS OF CHRONIC EXPOSURE OR TARGET ORGAN EFFECTS ARE KNOWN. NO EXPOSURE
LIMITS HAVE BEEN ESTABLISHED FOR THIS PRODUCT.
Explanation Of Carcinogenicity: NO CARCINOGENICITY, MUTAGENICITY OR
TERATOGENICITY ARE KNOWN.
Signs And Symptions Of Overexposure: INHALATION OF MIST MAY CAUSE IRRITATION OF
THE RESPIRATORY SYSTEM.
Medical Cond Aggravated By Exposure: NO DATA PROVIDED BY MANUFACTURER.
First Aid: SKIN: WASH AFFECTED AREA WITH SOAP AND WATER. EYE: IMMEDIATELY FLUSH
EYES WITH PLENTY OF COOL WATER FOR AT LEAST 15 MINUTES. DO NOT LET VICTIM RUB
EYES. GET MEDICAL ATTENTION IF IRRITATION DEVELOPS. I NHALATION: IMMEDIATELY
REMOVE VICTIM TO FRESH AIR. IF VICTIM HAS STOPPED BREATHING, GIVE ARTIFICIAL
RESPIRATION, PREFERABLY, MOUTH TO MOUTH. GET MEDICAL ATTENTION IMMEDIATELY.
INGESTION. CALL A PHYSIC IAN OR POISON CONTROL CENTER IMMEDIATELY.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: ADD DRY MATERIAL TO ABSORB SPILL (IF LARGE SPILL,
DIKE TO CONTAIN). USING RECOMMENDED PROTECTIVE EQUIPMENT, PICK UP BULK OF
SPILL AND CONTAINERIZE FOR RECOVERY OR DISPOSAL. FLUSH AREA WITH WATER TO RE
MOVE RESIDUES.
Neutralizing Agent: NO DATA PROVIDED BY MANUFACTURER.
Waste Disposal Methods: ALL RECOVERED MATERIAL SHOULD BE PACKAGED, LABELED,
TRANSPORTED, AND DISPOSED OR RECLAIMED IN CONFORMANCE WITH APPLICABLE LAWS
AND REGULATIONS AND IN CONFORMANCE WITH GOOD ENGINEERING PRACTICES. AVOID
LANDFILLING OF LIQUIDS. RECLAIM WHERE POSSIBLE.
Handling And Storage Precautions: NO SPECIAL PRECAUTIONS NECESSARY. AVOID
CONTAINER DAMAGE WHILE HANDLING AND STORING.
Other Precautions: NO DATA PROVIDED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: COC
Flash Point: =104.4C, 220.F
Autoignition Temp Text: N/D
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER SPRAY
Fire Fighting Procedures: USE WATER SPRAY, DRY CHEMICAL, FOAM OR CARBON
DIOXIDE. WATER MAY BE INEFFECTIVE BUT SHOULD BE USED TO KEEP FIRE EXPOSED
CONTAINERS COOL. IF A SPILL OR LEAK HAS NOT IGNITED, USE WATER SPRAY TO
DISPERSE THE VAPORS. WATER SPRAY MAY BE USED TO FLUSH SPILLS AWAY FROM FIRE.
Unusual Fire/Explosion Hazard: PERFORM ONLY THOSE FIRE FIGHTING PROCEDURES FOR
WHICH YOU HAVE BEEN TRAINED. FIREFIGHTERS SHOULD WEAR SELF CONTAINED
BREATHING APPARATUS IN THE POSITIVE PRESSURE MODE WITH A FULL FACEPIECE WHEN
THERE IS A POSSIBILITY OF EXPOSURE TO SMOKE, FUMES OR HAZARDOUS
DECOMPOSITION PRODUCTS.
=======================================================
Control Measures
=======================================================
Ventilation: GENERAL VENTILATION
Other Protective Equipment: NO DATA PROVIDED BY MANUFACTURER.
Work Hygienic Practices: NO DATA PROVIDED BY MANUFACTURER.
Supplemental Safety and Health: NO DATA PROVIDED BY MANUFACTURER
=======================================================
Physical/Chemical Properties
=======================================================
HCC: V6
B.P. Text: NOT DETERMINED
M.P/F.P Text: NOT DETERMINED
Vapor Pres: NOT DETERMINED
Vapor Density: N/D
Spec Gravity: 0.888
PH: NOT DETERMINED
Evaporation Rate & Reference: NOT DETERMINED
Solubility in Water: INSOLUBLE
Appearance and Odor: AMBER LIQUID, MILD ESTER ODOR
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NORMALLY STABLE. AVOID CONTACT WITH HEAT, SPARKS,
FLAME AND ALL SOURCES OF IGNITION
Materials To Avoid: STRONG ACIDS, BASES AND OXIDIZING AGENTS.
Hazardous Decomposition Products: DECOMPOSITION PRODUCES CARBON MONOXIDE AND
CARBON DIOXIDE
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: WILL NOT OCCUR
=======================================================
Toxicological Information
=======================================================
Toxicological Information: NO TOXICITY INFORMATION AVAILABLE OR TESTING
CONDUCTED ON THIS PRODUCT. ANY HEALTH TOXICOLOGICAL INFORMATION INCLUDED THE
ACUTE/CHRONIC HEALTH SECTION WAS BASED ON DATA ASSOCIATED WITH THE COMPONENTS
OR AN ANALOGOUS PRODUCT.
=======================================================
Ecological Information
=======================================================
Ecological: ENVIRONMENTAL TOXICITY: NOT DETERMINED. ENVIRONMENTAL FATE: NOT
DETERMINED.
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: SARA 311/312: NONE. SARA 313 TOXIC CHEMICALS: NONE.
SARA 302 EXTREMELY HAZARDOUS SUBSTANCES: NONE. CERCLA HAZARDOUS SUBSTANCES:
NONE.
Federal Regulatory Information: TSCA 12(B) COMPONENTS: NONE. TSCA INVENTORY
STATUS: THIS PRODUCT AND/OR ALL OF ITS COMPONENTS ARE INCLUDED ON THE TSCA
INVENTORY OF CHEMICAL SUBSTANCES.
State Regulatory Information: CALIFORNIA PROPOSITION 65 COMPONENTS: NONE.
=======================================================
Other Information
=======================================================
Other Information: RATINGS: HEALTH-1, FLAMMABILITY-1, REACTIVITY-0. NFPA
RATINGS: HEALTH-1, FLAMMABILITY-1, REACTIVITY-0, OTHER-NONE.
=======================================================
Transportation Information
=======================================================
Trans ID NO: 156060
Product ID: EMGARD 2810-A ARTIC 0W30 ENGINE OIL
Review Date: 02/22/2001
Net Unit Weight: 405 LBS
Multiple KIT Number: 0
Unit Of Issue: DR
Container QTY: 0
Type Of Container: 1A1 18/18GAGE
Additional Data: NOT REGULATED FOR SHIPPING PER MSDS.
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: EMGARD 2810-A ARTIC 0W30 ENGINE OIL
Cage: TO539
Assigned IND: Y
Company Name: COGNIC CORPORATION
Street: 5051 ESTECREEK DRIVE
Zipcode: 45232
Label Required IND: Y
Date Of Label Review: 02/22/2001
Status Code: A
Year Procured: 2001
Origination Code: F
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: NO
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE! TAGET ORGANS: N/P. HEALTH HAZARDS: NON
HAZARDOUS UNDER NORMAL CONDITIONS OF USE. FIRST AID:SKIN: WASH AFFECTED AREA
WITH SOAP AND WATER. EYE: IMMEDIATELY FLUSH EYES WITH PLENTY OF COOL WA TER
FOR AT LEAST 15 MINUTES. DO NOT LETVICTIM RUB EYES. GET MEDICAL ATTENTION IF
IRRITATION DEVELOPS. INHALATION: IMMEDIATELY REMOVE VICTIM TO FRESH AIR. IF
VICTIM HAS STOPPED BREATHING, GIVE ARTIFICI AL RESPIRATION, PREFERABLY, MOUTH
TO MOUTH. GET MEDICAL ATTENTION IMMEDIATELY.INGESTION. CALL A PHYSICIAN OR
POISON CONTROL CENTER IMMEDIATELY.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:C1613R419, CLASS/COPY CARTRIDGE
CAGE:0E6G9
CAGE:0E6G9
CAGE:26921
============= Composition/Information on Ingredients =============
Ingred Name:POLYCARBONATE RESIN
CAS:29936-68-3
Fraction by Wt: >40%
Ingred Name:CARBAZOLE DIPHENYLHYDRAZONE
Fraction by Wt: <30%
Ingred Name:HYDRAZONE DERIVATIVE
CAS:89505-08-8
Fraction by Wt: <10%
Ingred Name:P-CRESOL, 2,6-DI-TERT-BUTYL-; (DI-T-BUTYL HYDROXYTOLUENE).
MFR CAS NO:128-37-4
CAS:128-37-0
RTECS #:GO7875000
Fraction by Wt: <10%
Ingred Name:AROMATIC AMINE
CAS:67821-33-4
Fraction by Wt: <10%
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT):>5 G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NOT AN IRRITANT. NOT A SENSITIZER.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NONE
Medical Cond Aggravated by Exposure:NONE WHEN USED AS DESCRIBED BY
PRODUCT LITERATURE.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTIFICIAL RESPIRATION) .
EYES:IMMEDIATELY FLUSH WITH POTABLE WATER FOR A MINIMUM OF 15
MINUTES, SEEK AS SISTANCE FROM MD . SKIN:WASH WITHSOAP AND WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, CARBON DIOXIDE, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . WHEN IN A MACHINE, TREAT AS AN ELECTRICAL
FIRE.
Unusual Fire/Explosion Hazard:EXPOSURE TO HIGH TEMPERATURES CAN RESULT
IN MELTING & PYROLYSIS. FUMES MAY CAUSE RESPIRATORY SYMPTOMS.
DELAYED EFFECTS MAY OCCUR UP TO 72 HOURS.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:UNDER NO CIRCUMSTANCES SHOULD PUMICING
COMPOUNDS OR MECHANICAL ABRASION BE USED ON THIS PHOTORECEPTOR.
Other Precautions:AVOID EXPOSURE TO HIGH TEMPERATURES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NONE REQUIRED WHEN USED AS INTENDED IN
XEROX EQUIPMENT.
Ventilation:NONE REQUIRED WHEN USED AS INTENDED IN XEROX EQUIPMENT.
Other Protective Equipment:NONE REQUIRED WHEN USED AS INTENDED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:INSOLUBLE
Appearance and Odor:SOLID WITH NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ORGANIC SOLVENTS
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:CASUAL DISPOSAL LEADING TO INCINERATION OR
REGULAR LANDFILL ACCORDING TO LOCAL, STATE AND FEDERAL REGULATIONS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:HAVOLINE SUPREME SAE 10W-40, 01814
CAGE:7B131
CAGE:7B131
============= Composition/Information on Ingredients =============
Ingred Name:DIALKYLDITHIOPHOSPHORIC ACID, ZINC SALT
CAS:68649-42-3
Fraction by Wt: 1-3.99%
Ingred Name:CALCIUM PETROLEUM SULFONATE
CAS:61789-86-4
RTECS #:WR7140000
Fraction by Wt: 1-3.99%
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, SOLVENT-DEWAXED HEAVY
PARAFFINIC
CAS:64742-65-0
RTECS #:PY8038500
Fraction by Wt: 80-95%
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5MG/MG;10STEL (MIST)
Ingred Name:SUPP DATA: WATER, & LAUNDERING/DRY CLEANING SOILED WORK
CLTHG AT LEAST WEEKLY.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:(ORAL, RAT) - BELIEVED TO BE >5 G/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES/SKIN: BELIEVED TO BE
MINIMALLY IRRITATING. INHAL: BELIEVED TO BE MINIMALLY IRRITATING IF
NOT IN EXCESS OF PERMISSIBLE CONCENTRATIONS. USED GASOLINE MOTOR
OILS HAVE CAUSED SKIN CANCER IN LA BORATORY ANIMALS WHEN REPEATEDLY
APPLIED AND LEFT IN PLACE BETWEEN APPLICATIONS.
Explanation of Carcinogenicity:CAS NO.64742-65-0 IARC GROUP 1.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: AS W/MOST FOREIGN MATLS, SHLD CONTACT OCCUR, FLUSH
W/PLENTY OF WATER FOR A MINIMUM OF 15 MIN. SKIN: WASH EXPOSED AREAS
W/SOAP & WATER. INGEST: NONE CONSIDERED NECESSARY. CALL MD
IMMEDIATELY (FP N). INHAL: NONE CONSIDERED NECESSARY. REMOVE TO
FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP) .
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:435F,224C
Extinguishing Media:ACCORDING TO NFPA GUIDE, USE WATER SPRAY, DRY
CHEMICAL, FOAM, OR CARBON DIOXIDE. WATER OR FOAM MAY CAUSE
FROTHING.
Fire Fighting Procedures:USE WATER TO COOL FIRE-EXPOSED CONTRS. IF
LEAK/SPILLS HAS NOT IGNITED, USE WATER SPRAY TO DISPERSE VAPS & TO
PROVIDE PROT FOR PERSONS ATTEMPTING TO (SUPP DATA)
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL IF POSSIBLE. WIPE UP OR ABSORB
ON SUITABLE MATERIAL AND SHOVEL UP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:MINIMUM FEASIBLE HANDLING TEMP SHLD BE
MAINTAINED. PERIODS OF EXPOSURE TO HIGH TEMP SHLD BE MINIMIZED.
WATER CONTAMINATION SHLD BE AVOIDED.
Other Precautions:WARNING! AVOID SKIN CONTACT W/USED MOTOR OILS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED IF EXPOSURES ARE WITHIN
PERMISSIBLE CONCENTRATIONS. IF EXCEEDED, WEAR NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:ADEQUATE TO MEET COMPONENT PERMISSIBLE CONCENTRATIONS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:EXPOS EMPLOYEE SHLD EXERCISE REASONABLE
PERSONAL CLEANLINESS; THIS INCL CLEANSING EXPOS SKIN AREAS SEVERAL
(SUPP DATA)
Supplemental Safety and Health
FIRE FIGHT PROC: STOP LEAK. WEAR NIOSH/MSHA APPRVD SCBA/FULL PROT EQUIP
. WASTE DISP METH: PROD HAS BEEN EVALUATED FOR RCRA CHARACT & DOES
NOT MEET CRITERIA OF HAZ WASTE IF DISCARDED IN ITS PURC HASED FORM.
DISPOSAL MUST BE I/A/W ALL APPLIC LOC/STATE/FED REGS . HYGIENE
PRACT: TIMES DAILY W/SOAP & (ING 3)
================== Physical/Chemical Properties ==================
Spec Gravity:0.8812
Appearance and Odor:BRIGHT AND CLEAR LIQUID, MILD ADDITIVE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
THE MATERIAL REACTS VIOLENTLY WITH STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE/CARBON
DIOXIDE/ALDEHYDES & KETONES/ COMBUST PRODS OF NITROGEN/SULFUR/
CALCIUM/ZINC/COPPER/PHOSPHOROUS.
==================== Disposal Considerations ====================
Waste Disposal Methods:UNDER RCRA, IT IS THE RESPONSIBILITY OF USER OF
PRODS TO DETERMINE, AT THE TIME OF DISPOSAL, WHETHER PROD MEETS
RCRA CRITERIA FOR HAZ WASTE. THIS IS BECAUSE PROD
USES/TRANSFORMATIONS/ MIXTURE/PROCESSE S/ETC. MAY RENDER THE RSLTG
MATL HAZ. (SUPP DATA)
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:YELLOW 23538,ALKYD ENAMEL;745-308
CAGE:OO111
CAGE:09869
CAGE:OO111
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA (PETROLEUM SPIRITS OR BENZIN)
CAS:8030-30-6
RTECS #:SE7555000
OSHA PEL:100 PPM
===================== Hazards Identification =====================
Effects of Overexposure:INH:ANESTHETIC, IRRIT OF RESPT TRACT OR ACUTE
CNS DEPRSSN W/HDACHE,DIZ,UNCON,COMA. SKIN & EYE:IRRIT
======================= First Aid Measures =======================
First Aid:IN CASE OF CONTACT, FLUSH SKIN & EYE W/PLENTY OF WATER WHILE
REMOVING CONTAMINATED CLOTHING. IF INHALED, REOVE TO FRESH AIR.
CALL A PHYSICIAN IF SYMPTOMS PERSIST.
===================== Fire Fighting Measures =====================
Flash Point:85F TCC
Lower Limits:1.1
Extinguishing Media:SM FIRES:SCO*2,DRY CHEM. LG FIRES:POLYMER FOAM
PREFERRED
Fire Fighting Procedures:USE SELF-CONTAINED BREATING APPARATUS
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS EXPOSED TO HEAT MA
EXPLODE DUE TO PRESSURE BUILD-UP
================== Accidental Release Measures ==================
Spill Release Procedures:REOVE ALL SOURCES OF IGNITION (FLAME, HOT
SURFACES, & ELECTRICAL,STATIC, OR FRICTIONAL SPARKS). AVOID
BREATHING VAPORS.VENTILATE AREA.REMOVE W/INERT ABSRBENT &
NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F STORE LG QTY
IN BLDG DESIGNED TO STORE NFPACLASS ONE FLAM LIQ DO NOT TAKE
INTERNALLY. ADD LABEL WARNING.
Other Precautions:GROUND CONTANERS WHEN POURING. AVOID FREE FALL OF LIQ
IN EXCESS OF FEW IN. DO NOT FLAME CUT,BRAZE OR WELD COATED MATERIAL
W/O APPROVED RESPIRATOR OR APPROPRIATE VETILATION. DOT:FLAM LIQUID.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESTRICT VENT:CHEM-MECH FLTR.CLSD:AIR-LINE TYPE
Ventilation:GEN DILTN/LOCAL EXHST TO KEEP TLV/LEL BELOW LIMIT, REMV
FUME
Other Protective Equipment:AVOID LONG EXPOSURE TO CONTAM CLOTHING
Supplemental Safety and Health
THIS PRODUCT IS A SEMI-GLOSS ENAMEL. VAPOR PRESSURE:3.2;VAPOR
DENSITY:HEAVIER THAN AIR;WT PER GALLON 10.78 LBS
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:311-373F
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:59.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:AVOID FIRES, HEAT & HOT SURFACES
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE CLOSED CONTAINER. DISPOSE IN
ACCORDANCE W/FED.,STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:WATER SOLUBLE CUTTING OIL BULK, 26091
CAGE:99304
CAGE:99304
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED (MILD)
HEAVY NAPHTHENIC; (MINERAL OIL)
CAS:64742-52-5
RTECS #:PY8035000
Ingred Name:SULFONIC ACIDS, PETROLEUM; (SULFONATE-PETROLEUM)
CAS:61789-85-3
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Ingred Name:ETHANOL, 2-BUTOXY-; (DOWANOL EB)
CAS:111-76-2
RTECS #:KJ8575000
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
Ingred Name:DIETHYLENE GLYCOL; (GLYCOL-DIETHYLENE) (MFR CAS
NO:107-21-2)
CAS:111-46-6
RTECS #:ID5950000
Ingred Name:9-OCTADECENOIC ACID, (Z)-; (OLEIC ACID)
CAS:112-80-1
RTECS #:RG2275000
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ANIMAL STUDIES CLEARLY DEMONSTRATED
DOSE-RELATED ADVERSE EFFECTS ON CNS, HEMATOPOIETIC TISSUES, BLOOD,
KIDNEYS & LIVER, ASSOCIATED W/ADMINISTRATION OF ETHYLENE GLYCOL
MONOBUTYL ETHER (EGBE). (EXTRACTE D FROM DHHS (NIOSH) PUBLICATION
NO.9-118). . THIS PRODUCT HAS BEEN USED FOR YEARS W/NO ILL EFFECTS.
Explanation of Carcinogenicity:MINERAL OIL, PETROLEUM DISTILLATES,
HYDROTREATED (MILD) HEAVY PARAFFINIC:GROUP 1 (IARC).
Effects of Overexposure:EYE & SKIN IRRITATION.
Medical Cond Aggravated by Exposure:UNKNOWN.
======================= First Aid Measures =======================
First Aid:INGEST:DO NOT INDUCE VOMITING; GET MEDICAL ATTENTION.
SKIN:WASH W/SOAP & WATER. EYES:FLUSH W/FRESH WATER FOR AT LEAST 15
MINUTES. INHAL:REMOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:350F,177C
Extinguishing Media:WATERFOG, DRY CHEMICAL, FOAM, EARTH OR SAND.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . WATER MAY CAUSE FROTHING.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/SAND OR INERT MATERIAL & PLACE IN
CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM SPARKS & OPEN FLAMES.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NONE REQUIRED W/ADEQUATE VENTILATION.
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:APRON AS REQUIRED.
Work Hygienic Practices:WASH THOROUGHLY AFTER USE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:700F,371C
Spec Gravity:0.9 (H*2O=1)
Evaporation Rate & Reference:1 (BUTYL ACETATE=1)
Solubility in Water:100%
Appearance and Odor:FLUID OIL; BLAND ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, IGNITION.
Stability Condition to Avoid:OPEN FLAMES.
Hazardous Decomposition Products:CO & CO*2 IF INCOMPLETE COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FA439OA
CAGE:JO867
CAGE:81831
CAGE:JO867
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:INHAL:RESP TK IRRIT;
SKIN/EYE;IRRIT,INFLAM,CHLORACNE;MAY CAUSE LIVER DAMAGE
======================= First Aid Measures =======================
First Aid:INHAL:RMV TO FRESH AIR. IF NOT BRTHNG GIVE CPR. IF BRTHNG
DIFF,GIVE OXYGEN; EYE:IMMED FLUSH W/PLENTY OF WATER. SKIN:WASH
W/SOAP&WATER. RMV CONTAM CLTHG&SHOES. INGEST:INDUCE VOMIT. RPT
UNTIL VOMIT IS C LEAR. NOTHG BY MOUTH IF UNCONSC. GET MEDICAL ATTN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:MATL IS NON-FLAMMABLE BUT MAY GENERATE
TOXIC GASES IN HEAT OF FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVAC NON-ESSENTL PERSONNEL. VENT SPILL AREA.
WEAR PROTECPROTECT EQUIPT.STOP LEAK. SOAK UP LIQUID W/NON-REACTIVE
MATL (SAND, DIRT, ETC)OR RMV BY DIKE & PUMPING OR OTHER SUITABLE
MEANS. CLEAN AREA W/SUI TABLE SAFETY SOLVENT. LAUNDER CONTAMINATED
CLTHG.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL CONTACT. KEEP
CONTAINERS TIGHTLY CLOSED
Other Precautions:CHLORODIPHENYLS MAY ATTACK SOME TYPES OF RUBBER AND
PLASTIC. DO NOT USE CONTAMINATED WORK CLOTHING. WASH/SHOWER AFTER
EXPOSURE TO PCB'S.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MESA APPR SCBA/AIR SUPP RESPIR.
Ventilation:LOCAL EXHAUST TO MAINTN BELOW TLV.
Other Protective Equipment:WEAR FULL PROTECTIVE CLOTHING.
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS.CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE,THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Solubility in Water:NEGLIGIBLE
Appearance and Odor:PALE YELLOW VISCOUS LIQUID W/HYDROCARBON ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:SEE OTHER PRECAUTIONS
Hazardous Decomposition Products:HYDROGEN CHLORIDE,CO, & OTHER
TOXIC/IRRITATING GASES/FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQD. GEN. V.HIGH TEMP
INCINERATION. IN ACCORDANCE WITH ALL LOCAL, STATE, & FEDERAL
REGULATIONS. PERMITTED DISPOSAL OPERATOR REQUIRED.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BLACK DEVELOPER DC-1824ZII
CAGE:65678
CAGE:65678
============= Composition/Information on Ingredients =============
Ingred Name:IRON (III) OXIDE
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 66%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG(FE)/M3 FUME, B2
Ingred Name:ZINC OXIDE (SARA 313) (CERCLA)
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: 14%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CALCIUM OXIDE
CAS:1305-78-8
RTECS #:EW3100000
Fraction by Wt: 1%
OSHA PEL:5 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:TONER; (BLACK TONER FOR DC-111)
Fraction by Wt: 5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:COPPER OXIDE; (COPPER OXIDES)
CAS:1317-38-0
RTECS #:GL7900000
Fraction by Wt: 14%
OSHA PEL:1 MG CU/M3
ACGIH TLV:1 MG CU/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:NONE IN NORMAL HANDLING AND USE.
SIGNS AND SYMPTOMS OF EXPOSURE:MINIMAL RESPIRATORY TRACT IRRITATION
MAY OCCUR AS WITH EXPOSURE TO LARGE AMOUNTS OF ANY NON-TOXIC DUST.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NOT APPLICABLE.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . SKIN:WASH WITH SOAP AND WATER. EYE:FLUSH THOROUGHLY WITH
WATER FOR AT LEAST 15 MINUTES AND SEEK MEDICAL TREATMENT.
INGEST:DILU TE STOMACH CONTENTS WITH SEVERAL GLASSES OF WATER AND
SEEK MEDICAL TREATMENT.
===================== Fire Fighting Measures =====================
Extinguishing Media:IF PRODUCT BECOMES INVOLVED IN A FIRE USE CARBON
DIOXIDE EXTINGUISHER. WATER, FOAM OR DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE UNDER NORMAL STORAGE AND USE
CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP WITH A VACUUM CLEANER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CLOSE CAP TIGHTLY AND STORE IN A COOL,
DRY AND DARK PLACE.
Other Precautions:AVOID COMBUSTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL USE. NIOSH APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE REQUIRED UNDER NORMAL USE.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:AVOID INHALATION, INGESTION, SKIN OR EYE
CONTACT.
Supplemental Safety and Health
SOL IN H*2O:INSOLUBLE/NEGLIGIBLE (TOLUENE).
================== Physical/Chemical Properties ==================
Spec Gravity:1.85 (WATER =1)
Solubility in Water:SUPP DATA
Appearance and Odor:FINE BLACK POWDER, PRACTICALLY ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE IN NORMAL HANDLING AND USE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:POTASSIUM PERMANGANATE
CAGE:1HA92
CAGE:1HA92
============= Composition/Information on Ingredients =============
Ingred Name:PERMANGANIC ACID, POTASSIUM SALT; (POTASSIUM PERMANGANATE)
CAS:7722-64-7
RTECS #:SD6475000
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:WATER; (DEMINERALIZED WATER)
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: TO 100%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS PRODUCT MAY BE IRRITATING TO EYES
AND SKIN. CORROSIVE TO SKIN ON CONTACT. POISONOUS IF SWALLOWED.
CHRONIC: DERMATITIS AND TEMPORARY DARKENING OF SKIN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE REPORTED.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
OXYGEN/ARTIFICIAL RESPIRATION) . EYES: IMMEDIATELY FLUSH EYES WITH
PLENTY OF WATER FOR AT LEAST 15 MINUTES. HOLD EYELIDS OPEN TO
ENSURE COMPLE TE RINSING OF EYE. CALL MD. SKIN: IMMEDIATELY FLUSH
SKIN WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. CALL MD. INGEST:
DRINK A LARGE QUANTITITY OF MILK OR WATER. CALL MD.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT APPLICABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE AND DAM LARGE SPILLS. RECOVER, PUMP TO
CONTAINERS OR SOAK UP ON INERT ABSORBENT FOR PROPER DISPOSAL.
CONSULT AUTHORITIES FOR REGULATIONS REGARDING THE DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN DARK OR AMBER BOTTLE.
Other Precautions:AVOID CONTACT WITH EYES AND SKIN AND CLOTHING. WASH
HANDS AND CLOTHES THOROUGHLY AFTER HANDLING. KEEP OUT OF REACH OF
CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EYE PROT: & FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:210F,99C
Spec Gravity:1.0
pH:7.0
Solubility in Water:100%
Appearance and Odor:DARK, PURPLE SOLUTION; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE
AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:KAOLITE 3000 G
CAGE:EO710
CAGE:19740
CAGE:EO710
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE
CAS:14464-46-1
RTECS #:VV7325000
Fraction by Wt: 0-15%
Other REC Limits:0.05 MG/CUM NIOSH
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.05 MG/M3 RDUST9293
Ingred Name:SILICA, CRYSTALLINE - FUSED
CAS:60676-86-0
RTECS #:VV7328000
Fraction by Wt: 0-15%
Other REC Limits:30 MG/CUM TOTAL DUST
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:PARTICULATES NOT OTHERWISE REGULATED (NUISANCE DUST)
Fraction by Wt: >80%
OSHA PEL:15 MG/M3 TOTAL DUST
ACGIH TLV:10 MG/M3 TDUST; 8990
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE DELAYED LUNG
INJURY (SILICOSIS). EYES/SKIN: MAY CAUSE TEMPORARY IRRITATION OR
DISCOMFORT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NUISANCE DUST MAY CAUSE NASAL/THROAT/LUNG
IRRITATION/DISCOMFORT: MAY AGGRAVATE BRONCHIAL DISORDERS
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. INGESTION: DRINK PLENTY OF
WATER. SKIN: WASH W/MILD SOAP & WATER. EYES: FLUSH W/PLENTY OF
WATER, IF IRRITATION PERSISTS, CALL A PHYSICIAN.
================== Accidental Release Measures ==================
Spill Release Procedures:FOLLOW ROUTINE HOUSEKEEPING PROCEDURES.
======================Handling and Storage ======================
Handling and Storage Precautions:THIS PRODUCT AS MANUFACTURED IS AN
ALUMINOSILICATE WHICH COULD TRANSFORM UPON HEATING TO
MULLI/CRISTOBALITE (A FORM OF CRYSTALLINE SILICA).
Other Precautions:REMOVAL OF THIS PRODUCT AFTER USE MAY RESULT IN THE
GENERATION OF DUST. REPEATED INHALATION OF RESPIRABLE FREE
CRYSTALLINE SICA DUST MAY CAUSE DELAYED LUNG INJURY (SILICOSIS)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED OR FULL FACEPIECE RESPIRATOR
W/APPROPRIATE FILTER PAD
Ventilation:LOCAL EXHAUST AND MECHANICAL
Other Protective Equipment:AS REQUIRED TO MEET APPLICABLE OSHA
STANDARDS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:0.9-3.1
Solubility in Water:INSOLUBLE
Appearance and Odor:COARSE AGGREGATE WITH FINE POWDERED MATRIX
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTES ARE NOT HAZARDOUS WASTES AS DEFINED BY
RCA (40 CFR 261). COMPLY W/FEDERAL, STATE & LOCAL REGULATIONS.
METHOD OF DISPOSAL IS LANDFILL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ANDOK C: INDUSTRIAL LUBRICATING GREASE
CAGE:GO864
CAGE:GO864
CAGE:29700
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM HYDROCARBONS
Ingred Name:SODIUM SOAP
Ingred Name:ADDITIVES
===================== Hazards Identification =====================
Effects of Overexposure:SKIN: IRRIT W/PROLONGED/REPEATED CNTCT. GREASE
INJECTED IN BODY: SERIOUS DELAYED SOFT TISSUE DAMAGE.
======================= First Aid Measures =======================
First Aid:SKIN: WASH THOROUGHLY W/SOAP & WARM WATER. EYES: FLUSH
W/CLEAR WATER 15 MIN OR UNTIL IRRIT SUBSIDES. INJECTED UNDER SKIN:
HI PRESS GREASE GUN INJECTION INJURY, REGARDLESS OF APPEARNACE OF
WOUND, SEE M D IMMED. POSS LOSS OF AFFECTED AREA.
===================== Fire Fighting Measures =====================
Flash Point:390F COC
Lower Limits:1.0
Upper Limits:6.0
Extinguishing Media:FOAM, DRY CHEM, CO*2, WATER FOG, SPRAY
Fire Fighting Procedures:AIR-SUPP BRTH EQUIP. COOL CANS W/WATER SPRAY.
AVOID FUMES.
Unusual Fire/Explosion Hazard:DO NOT MIX OR STORE W/STRONG OXIDANTS
LIKE LIQ CHLORINE OR CONC OXYGEN
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER FREE LUBRICANT. ADD ABSORBENT: SAND,
SAWDUST, ETC, TO SPILL AREA. KEEP PETROL PROD OUT OF SEWERS &
WATERCOURSES BY DIKING OR IMPOUNDING. ADVISE AUTH IF PROD HAS
ENTERED OR MAY ENTER SEWERS OR WATERCOURSES.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNRS CLOSED WHEN NOT IN USE. DO
NOT HANDLE OR STORE NEAR HEAT, SPARKS, FLAME, STRONG OXIDANTS.
Other Precautions:AVOID BRTHNG OIL MIST. REMOVE LUBRICANT-SOAKED
CLOTHING & LAUNDER BEFORE REUSE. DISCARD LUBRICANT-SOAKED SHOES.
WASH SKIN THOROUGHLY W/SOAP & WATER AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMALLY NOT NEEDED. IF NEC, USE NIOSH/MSHA
APPRVD RESP DEVICE.
Ventilation:MFR REC LOCAL EXHST
Other Protective Equipment:CHEM RESIST APRON OR OTHER PROT CLOTHING TO
AVOID SKIN CNTCT
Supplemental Safety and Health
VAP PRESS <0.01, VAP DNSTY >12
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:>500F IBP
Spec Gravity:0.9500
Evaporation Rate & Reference:<0.01, N-BUAC
Solubility in Water:APPRECIABLE
Appearance and Odor:DARK BROWN GREASE, VERY SLT DISTNCT AROMATIC ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS: LIQ CHLORINE, CONC OXYGEN NA/CA HYPCHLRITE
Hazardous Decomposition Products:FUMES, SMOKE, CO, SULFUR OXIDES IN
CASE OF INCMPLT COMBUST
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ABSORBED MATL AT APPRVD WASTE
DISPOSAL SITE OR FACILITY. DISPOSE IAW FED, STATE, LOCAL CODES.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ISOPROPYL ALCOHOL
CAGE:61084
CAGE:61084
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 100%
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
===================== Hazards Identification =====================
Effects of Overexposure:IRRITATING TO SKIN,HARMFUL TO EYES. VAPOR MAY
CAUSE HEADACHES, NAUSEA,VOMITING.
======================= First Aid Measures =======================
First Aid:USE STANDARD FIRST AIR PROCEDURES. CALL EMERGENCY MEDICAL
CARE.
===================== Fire Fighting Measures =====================
Flash Point:77F/25C(TCC)
Extinguishing Media:CO*2, FOAM, DRY CHEM.
Fire Fighting Procedures:USE CLASS "C" FIRE EXTINGUISHER.
Unusual Fire/Explosion Hazard:CAN RELEASE FLAMMBLE VAPORS UPON HEATING.
================== Accidental Release Measures ==================
Spill Release Procedures:COLLECT ON ABSORBENT INERT MATERIAL AND
DISPOSE OF AS OUTLINED BELOW. VAPOR IS FLAMMABLE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY WELL VENTED,LOW FIRE
RISK AREA. PROTECT FR HEAT,SHOCK KEEP CONTAINERS CLOSED.
Other Precautions:WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FILTER MASK
Ventilation:YES
Other Protective Equipment:APRON
Supplemental Safety and Health
MSDS DATED 1-24-86.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:176F/80C
Spec Gravity:0.78
Solubility in Water:INFINITE
Appearance and Odor:CLEAR COLORLESS SOLN.SLIGHT ETHANOL/ACETONE ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENT.
Stability Condition to Avoid:HEAT,SPARK,FLAME.
Hazardous Decomposition Products:FLAMMBALE VAPORS.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TYPE S MORTAR (WR), WALL MUD
CAGE:VALAB
CAGE:VALAB
============= Composition/Information on Ingredients =============
Ingred Name:SILICATE, PORTLAND CEMENT; (PORTLAND CEMENT)
CAS:65997-15-1
RTECS #:VV8770000
OSHA PEL:50 MPPCF
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:LIME (HYDRATED); (LIME (TYPE S))
CAS:39445-23-3
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR
Ingred Name:NATURAL SAND
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (CRYSTALLINE SILICA)
CAS:14808-60-7
RTECS #:VV7330000
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:GLUCONIC ACID, MONOSODIUM SALT, D-; (SODIUM GLUCONATE)
CAS:527-07-1
RTECS #:LZ5235000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:IN PRESENCE OF MOISTURE, CONT
W/SKIN & EYES WILL CAUSE IRRIT & POSS SEV CORR DMG. ACUTE/RAPIDLY
DEVELOPING SILICOSIS MAY OCCUR IN SHORT TIME IN HVY EXPOS TO SILICA
DUST. SYMPS:INHAL:UNDUE BREATH LESSNESS, WHEEZING, COUGHING &
SPUTUM PRODUCTION. CONT W/SKIN/EYES:BURNING & IRRIT, (EFTS OF
OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC
MONOGRAPHS, SUPP. VOL 7, PG 341, 1987:GROUP 2A. NTP 7TH ANNUAL RPT
ON CARCINS. (SUPDAT)
Effects of Overexposure:HLTH HAZS:DRY SKIN & ALKALI BURNS. MAY CAUSE AN
ALLERGIC DERM (SKIN RASH). SKIN ABSORB:N/A. INGEST:VOMIT.
CHRONIC:PRLNGD EXPOS TO RESP CRYSTALLINE QUARTZ MAY CAUSE DELAYED
LUNG INJURY (SILICOSIS). SIL ICOSIS IS A FORM OF DISABLING PULM
FIBROSIS WHICH CAN BE PROGRESSIVE & MAY LEAD TO DEATH.
Medical Cond Aggravated by Exposure:PULM FUNCTION MAY BE REDUCED BY
INHAL OF RESP CRYSTALLINE SILICA. ALSO, LUNG SCARRING PRDCED BY
SUCH INHAL MAY LEAD TO PROGRESSIVE MASSIVE FIBROSIS OF LUNG WHICH
MAY AGGRAVATE OTHER PULM (SUPP DATA)
======================= First Aid Measures =======================
First Aid:EYES:WASH IMMED W/RUNNING WATER FOR @ LST 15 MIN, INCLUDING
UNDER LIDS. GET PROMPT MED ATTN. SKIN:WASH EXPOSED AREA W/LG AMTS
OF SOAP & WATER. REMOVE & WASH CONTAM CLTHG. APPLY SKIN LOTION.
INHAL:REMO VE FROM EXPOS TO DUST & GET PROMPT MED ATTN.
INGEST:IMMED DILUTE CHEM BY DRINKING LG AMTS OF WATER/MILK, THEN
NEUT BY DRINKING DILUTED VINEGAR/FRUIT JUICE. GET PROMPT MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:NON COMBUSTIBLE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT APPLICABLE. HYDRATED LIME DEHYDRATES
TO MAGNESIUM OXIDE (350C/662F) & CALCIUM OXIDE (580C/1079F) &
STEAM. PROTECT EYES FROM DUST. NON EXPLOSIVE.
================== Accidental Release Measures ==================
Spill Release Procedures:USE DRY CLEAN UP METHODS THAT DO NOT DISPENSE
THE DUST INTO THE AIR. AVOID BREATHING THE DUST. EMERGENCY
PROCEDURES ARE NOT REQUIRED. WEAR PROTECTIVE EQUIPMENT SPECIFIED IN
CONTROL MEASURES.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID GENERATING DUST. KEEP MATERIAL
DRY. AVOID CONTACT WITH INCOMPATIBLE MATERIALS.
Other Precautions:HOW TO DETECT THIS SUBSTANCE: (WARNING PROPERTIES OF
SUBSTANCE AS A GAS, VAPOR, DUST OR MIST).
============= Exposure Controls/Personal Protection =============
Respiratory Protection:INDUSTRY ENVIRONMENTS, THE USE OF A MSHA/NIOSH
APPROVED RESPIRATOR IS RECOMMENDED.
Ventilation:USE SUFFICIENT LOC EXHST TO REDUCE LEVEL OF RESP
CRYSTALLINE SILICA TO PEL. SEE ACGIH INDUST VENT, MANUAL OF REC
PRACT.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER . PROT CLTHG TO PVNT SKIN FROM PRLNGD CONT W/WET MORTAR.
Work Hygienic Practices:WORKERS SHOULD SHOWER WITH SOAP AND WATER
IMMEDIATELY AFTER HANDLING MATERIAL.
Supplemental Safety and Health
MATLS TO AVOID:FIRES. ALSO AVOID AMMONIUM SALTS, PHOSPHORUS & ORG
CMPDS. EXPLAN OF CARCIN:1994:ANTIC TO BE CARCIN. ANIMAL:LUNG. MED
CNDTNS:CONDITIONS & DISEASES WHICH INCREASE SUSCEPTIBILITY TO
PULMON ARY TUBERCULOSIS.
================== Physical/Chemical Properties ==================
Spec Gravity:2.0
Solubility in Water:<1
Appearance and Odor:GREY POWDER-NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONT W/OXIDIZING AGENTS SUCH AS:FLUORINE, CHLORINE, TRIFLUORINE,
MANGANESE TRIOXIDE, OXYG DIFLUORIDE, MAY CAUSE (SUPDAT)
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:SILICA WILL DISSOLVE IN HYDROFLUORIC
ACID AND PRODUCE A CORROSIVE GAS-DILICON TETRAFLUORIDE.
Conditions to Avoid Polymerization:HANDLING PROCEDURES WHICH MAY
GENERATE DUST. CONTACT WITH NITROPARAFFINS, MALEIC ANHYDRIDE OR
PHOSPHORONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:SMALL AMOUNTS OF MATERIAL CAN BE DISPOSED OF AS
COMMON WASTE OR RETURNED TO THE CONTAINER FOR LATER USE IF IT IS
NOT CONTAMINATED. LARGE VOLUMES MAY REQUIRE SPECIAL HANDLING.
NOTE:DISPOSE OF ALL WASTE S IN ACCORDANCE WITH FED, STATE & LOC
REGS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SUPER STAINLESS STEEL ALLOYS, 330 (8432)
Preparer's Name:W.J. HETRICK
CAGE:0VZP9
CAGE:0VZP9
CAGE:70787
============= Composition/Information on Ingredients =============
Ingred Name:ING 24:FUME. IF USE OF MATL PRDCES DUST/FUME, USE APPROP
VENT CONTROLS, PPE/BOTH. FOR ADDNL INFO REFER TO MSDS FOR PROD.
RTECS #:9999999ZZ
Ingred Name:ING 10:LUNG CANCERS. IRON HAS BEEN INDICATED TO CAUSE GI
DISORDERS & NON-SIGNIFICANT CHANGES IN LUNG. HLTH EFTS (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:SPECIFIC TO ELEMENT(S) MAY BE DFCLT TO DETECT DUE TO
NUMEROUS ELEMENTAL CONSTITUENTS IN THIS ALLOY. (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:CHROMIUM HAS BEEN LISTED IN 3RD ANNUAL REPORT ON
CARCINS AS PREPARED BY NTP & IARC.
RTECS #:9999999ZZ
Ingred Name:MED CNDTNS:INCUR FURTHER DISABILITY IF EXCESS CONCS OF
DUST/FUME ARE INHALED. IF PRIOR DMG/DISEASE TO NEUROLOGIC(ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:(NERV), CIRCULATORY, HEMATOLOGIC
(BLOOD)/RENAL(KIDNEY) SYS HAS OCCURED, PROPER SCREENING/EXAMS
SHOULD BE (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:CONDUCTED ON PERSONS WHO MAY BE EXPOSED TO FURTHER
RISK IF HANDLING & USE OF THIS MATL CAUSES EXCESSIVE EXPOSURE.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:TESTS, CHEST X-RAYS & ROUTINE PHYSICAL EXAMS
MAY BE USEFUL TO DETERMINE EFTS OF DUST/FUME EXPOSURE.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:PWDR/DUST & AVOID CONTAM OF AIR & WATER.
PROPERLY LBL ALL MATLS COLLECTED IN WASTE CNTNR. METAL PWDRS(ING
19)
RTECS #:9999999ZZ
Ingred Name:ING 18:OR DUSTS MAY HAVE SIGNIFICANT IMPACT ON AIR & WATER
QUALITY. AIRBORNE EMISSIONS, SPILLS & RELS TO ENVIRON(ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19:(DISCHARGE TO STREAMS, SEWER SYS, GROUND WATER, SURF
SOIL, ETC) SHOULD BE CONTROLLED IMMED. IF SUCH (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20:POTNTL FOR SPILL/RELS EXISTS IT IS ADVISABLE TO
DEVELOP AN EMERGENCY SPILL RESPONSE PLAN.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:DUST, FUME/PWDR CAN CAUSE INGEST OF PARTICULATE
DURING HAND TO MOUTH ACTIVITIES SUCH AS EATING, (ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22:DRINKING, SMOKING, NAIL BITING, ETC. AIRBORNE
PARTICULATE (CHIPS, DUST/PWDR) IS ALWAYS POTNTL PROB AS (ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23:WELL AS INSERTING FINGERS INTO EYE SOCKET IF
HAND/CLTHG IS CONTAM W/METAL PARTICULATE. AVOID BRTHG DUST/ (ING
25)
RTECS #:9999999ZZ
Ingred Name:CHROMIUM; (CR) (SARA 313) (CERCLA)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 19%
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:COPPER; (CU) (SARA 313) (CERCLA)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 0.5% MAX
OSHA PEL:0.1MG/M3 FUME;1 DUST
ACGIH TLV:0.2 MG/M3 FUME
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:IRON (III) OXIDE; (FE)
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 40%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3 FUME (FE)
Ingred Name:MANGANESE; (MN) (SARA 313)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 2% MAX
OSHA PEL:5 MG/M3 DUST, C
ACGIH TLV:5 MG/M3 DUST
Ingred Name:MOLYBDENUM; (MO)
CAS:7439-98-7
RTECS #:QA4680000
Fraction by Wt: 0.5% MAX
OSHA PEL:10 PPM
ACGIH TLV:10 PPM
Ingred Name:NICKEL; (NI) (SARA 313) (CERCLA)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 36%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:SILICON; (SI)
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: 1.3%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:EFTS OF OVEREXP:W/SYMPS RANGING FROM SHORTNESS OF BREATH &
COUGH TO PERM DISABILITY DUE TO LOSS OF LUNG FUNC, (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:FIBROSIS/SUBSEQUENT EFTS ON HEART MAY BE CAUSED BY
EXCESS EXPOS TO DUST/FUMES CNTNG ING 6. CNS DEPRESS HAS(ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:BEEN IDENTIFIED W/EXCESS MANGANESE EXPOS. INGS 1,6 &
CERTAIN CMPDS HAVE BEEN LINKED TO NASAL, BRONCH & (ING 11)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:UNDER NORM HNDLG & USE OF SOLID FORM
OF MATL THERE ARE FEW HLTH HAZS. CUTTING, WELDING, MELTING,
GRINDING, ETC WILL PRDCE DUST, FUME/PARTICULATE CNTNG COMPONENT
ELEMENTS OF THIS MATL. ACUTE:METAL DUST & FUMES OF INGS CAN CAUSE
IRRIT TO SKIN, EYES & MUC MEMBS. CONT W/INGS 1,2,6 MAY CAUSE
ALLERGIC SKIN (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NICKEL:IARC MONOGRAPHS ON EVAL OF CARCIN
RISK OF CHEMS TO MAN, VOL 49, PG 257, 1990:GRP 2B. NTP 7TH ANNUAL
RPT (SUPDAT)
Effects of Overexposure:HLTH HAZ:RXNS. AS DUST, PWDR/FUME, EXPOS WHICH
ABRADES SKIN CAN CAUSE IRRIT & DERM. INJURY TO EYES IS GENRLY RSLT
OF PARTICULATE IRRIT/MECH INJURY TO CORNEA/CONJ BY
DUST/PARTICULATE. EXCESSIVE INHAL O F INGS 2,4,6 CAN CAUSE RESP
IRRIT, COUGH, BRONCH, CHILLS, "FUME FEVER" & ASTHMA-LIKE SYMPS.
CHRONIC:RESP DISEASE (ING 8)
Medical Cond Aggravated by Exposure:PERS WHO MAY HAVE HAD ALLERGIC
RXN/SENSITIVITY TO METALS MAY ENCOUNTER SKIN RASH/DERM. PERS
W/IMPAIRED PULM FUNC, AIRWAY DISEASES & CNDTNS SUCH AS ASTHMA,
EMPHYSEMA, CHRONIC BRONCH, ETC, MAY (ING 14)
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. IF BRTHG HAS STOPPED, PERFORM ARTF
RESP & OBTAIN MD ATTN AT ONCE. INGEST:HAVE AFFECTED PERS SWALLOW LG
QTYS OF WATER & ATTEMPT TO INDUCE VOMIT IF CONSCIOUS. OBTAIN MED
ATTN IMMED. SKIN:WASH W/SOAP & WATER. IF IRRIT PERSISTS, OBTAIN
MED ATTN. EYES:FLUSH W/COPIOUS AMTS OF CLEAN WATER FOR AT LST 15
MINS. IF IRRIT PERSISTS OBTAIN MED ATTN. MED SURVEILLANCE:LUNG FUNC
(ING 17)
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:USE EXTING MEDIA APPROP TO SURROUNDING FIRE. TO
EXTING METAL PWDR FIRE USE DRY SAND, DRY GRAPHITE/OTHER CLASS
(SUPDAT)
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . IF THIS MATERIAL IS REDUCED TO POWDER FORM, CAUTION
MUST BE USED TO PREVENT FIRE OR EXPLOSION.
Unusual Fire/Explosion Hazard:NONCOMBUSTIBLE. NO UNUSUAL FIRE OR
EXPLOSION HAZARDS ARE ASSOCIATED W/THIS MATERIAL.
================== Accidental Release Measures ==================
Spill Release Procedures:IN SOLID FORM MATL POSES NO SPECIAL
CLEAN-UP/ENVIRON PROBS. IF MATL IS IN PWDR/DUST FORM, CLEAN-UP
SHOULD BE CONDUCTED W/VACUUM SYS UTILIZING HIGH EFFICIENCY
PARTICULATE AIR FILTRATION SYS. CAUT SHOUL D BE TAKEN TO MIN
AIRBORNE GENERATION OF (ING 18)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PROD MUST BE HNDLD ACCORDINGLY TO
SIZE, SHAPE & QTY OF MATL INVOLVED. SOLID METAL MAY REQ USE OF
HOISTS, CRANES, ETC. PWDRS SHOULD BE MOVED/ (SUPDAT)
Other Precautions:IN SOLID FORM MATL POSES NO SPECIAL STOR PROBS. STORE
METAL & METAL PWDR IN DRY AREA. DO NOT STORE ADJACENT TO MINERAL
ACIDS. FINE METAL PWDR SHOULD BE KEPT AWAY FROM FLAMES & SOURCES OF
IGNIT. HAND, CLTHG, FOOD & DRINK CONT W/METAL(ING 22)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATORS AS SPECIFIED BY
INDUSTRIAL HYGIENIST OR QUALIFIED SAFETY PROFESSIONAL. LUNG
FUNCTION TESTS ARE RECOMMENDED FOR USERS OF NEGATIVE PRESSURE
DEVICES.
Ventilation:LOC EXHST VENT SHOULD BE USED TO CONTROL EXPOS TO AIRBORNE
DUST & FUME WHENEVER POSS. EXPOS CAN BE BEST DETERM (SUPDAT)
Other Protective Equipment:ANSI APPRVD EYE WASH FOUNTAIN & DELUGE
SHOWER . PROT CLTHG SUCH AS UNIFORMS, DISPOSABLE COVERALLS, SAFETY
(SUPDAT)
Work Hygienic Practices:CONTACT LENSES SHOULD NOT BE WORN IF WORKING
W/METAL DUSTS & POWDERS.
Supplemental Safety and Health
EXTING MEDIA:"D" FIRE EXTING PWDR. EXPLAN OF CARCIN:ON CARCINS,
1994:ANTIC TO BE CARCIN. ANIMAL:LUNG, NASAL CAVITIES. HNDLG/STOR
PREC:TRANSPORTED TO MIN SPILL/RELS POTNTL. VENT:BY HAVING AIR
SAMPLES T AKEN IN EMPLOYEE BRTHG ZONE, WORK AREA/DEPT. OTHER PROT
EQUIP:SHOES, ETC MAY BE REQD DURING METAL HNDLG OPERATIONS.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:2550F,1399C
Spec Gravity:0.29
Solubility in Water:NONE
Appearance and Odor:SOLID - SILVER GRAY COLOR; NO ODOR.
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONT W/MINERAL ACIDS & OXIDIZING AGENTS WHICH MAY GENERATE
HYDROGEN GAS; EVOLUTION OF HYDROGEN MAY BE EXPLO HAZ.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:VARIOUS ELEMENTAL METALS & METAL
OXIDES MAY BE GENERATED FROM MELTING OR DROSS HANDLING OPERATIONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISP MUST BE I/A/W FED, STATE & LOC REGS . PRIOR
TO DISP CONSIDER IF MATL HAS RECOVERY VALUE. STATE/FED REGS MAY REQ
SPECIFIC LABELING, PACKING, STOR, TRANSPORTATION & DISP PROCS. CONT
ENVIRON E NGINEER/CONSULTANT FAMILIAR W/WASTE DISP REGS.
| 1 | eyes_protection_mandatory |
=======================================================
NIIN: 01-418-7782
Product ID: NICKEL CADMIUM BATTERIES (NICD) ALL MODELS/SIZES
Article: Y
Cage: 0J4G8
Resp. Party Other MSDS No.: REVISION B
=======================================================
Contractor Summary
=======================================================
Cage: 0J4G8
Cage: 0PK96
=======================================================
Item Description Information
=======================================================
Item Manager: S9G
Item Name: BATTERY ASSEMBLY
Unit of Issue: EA
UI Container Qty: 0
=======================================================
Regulated Components
=======================================================
Regulated Component Name: NICKEL HYDROXIDE (NI(OH)2)
CAS: 12054-48-7
Regulated Component Name: CADMIUM
CAS: 7440-43-9
=======================================================
Health Hazards Data
=======================================================
Effects of Exposure: NICKEL CADMIUM BATTERIES DO NOT LEAK ELECTROLYTE UNDER
NORMAL USAGE CONDITIONS. SEVERELY OVERCHARGED OR ABUSED BATTERIES MAY LEAK
SMALL AMOUNTS OF ELECTROLYTE. THE BATTERIES REFERENCED HEREIN ARE EXEM PT
ARTICLES AND ARE NOT SUBJECT TO THE OSHA HAZARD COMMUNICATION STANDARD
REQUIREMENT. THIS SHEET IS PROVIDED AS A SERVICE TO OUR CUSTOMERS.
Explanation Of Carcinogenicity: THE BATTERIES REFERENCED HEREIN ARE EXEMPT
ARTICLES AND ARE NOT SUBJECT TO THE OSHA HAZARD COMMUNICATION STANDARD
REQUIREMENT. THIS SHEET IS PROVIDED AS A SERVICE TO OUR CUSTOMERS.
Signs And Symptions Of Overexposure: BECAUSE ALL OF OUR BATTERIES ARE DEFINED
AS "ARTICLES", THEY ARE EXEMPT FROM THE REQUIREMENTS OF THE HAZARD
COMMUNICATION STANDARD, HENCE A MSDS IS NOT REQUIRED.
First Aid: IN CASE OF SKIN EXPOSURE, WASH ANY EXPOSED SKIN WITH COPIOUS AMOUNTS
OF WATER.
=======================================================
Handling and Disposal
=======================================================
Waste Disposal Methods: IN THE EVENT OF DISPOSAL, DISPOSE ONLY IN ACCORDANCE
WITH FEDERAL, STATE AND LOCAL REGULATION. BATTERIRES GENERATED AS A WASTE ARE
SUBJECT TO THE RESOURCE CONSERVATION AND RECOVERY ACT (RCRA) AS A D00 6
(CADMIUM) HAZARDOUS WASTE. ALL NICKEL CADMIUM BATTERIES ARE CLASSIFIED AS A
D006 HAZARDOUS WASTE B ECAUSE OF THE PRESENCE OF CADMIUM.
GLASSES WHEN HANDLING LEAKING BATTERIES.
=======================================================
Fire and Explosion Hazard Information
=======================================================
=======================================================
Control Measures
=======================================================
BATTERIES.
BATTERIES.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: Z5
=======================================================
Reactivity Data
=======================================================
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
Transport Information: PANASONIC SEALED NICKEL CADMIUM BATTERIES ARE CONSIDERED
TO BE "DRY CELL" BATTERIES AND ARE UNREGULATED FOR PURPOSES OF TRANSPORTATION
BY THE US DOT, ICAO, IATA AND IMO/IMDG. THE ONLY DOT REQUIREMENT FOR THESE
BATTERIES IS SPECIAL PROVISION 130 WHICH STATES: "BATTERIES, DRY ARE NOT
SUBJECT TO THE REQUIREMENTS OF THIS SUBCHAPTER ONLY WHEN THEY ARE OFFERED IN
TRANSPORTATION IN A MANNER THAT PREVENTS THE DANGEROUS EVOLUTION OF HEAT. AS
OF 1/1/97 IATA REQIRES THAT BATTERIES BEING TRANSPORTED BY AIR MUST BE
PROTECTED FROM MOVEMENT THAT COULLD LEAD TO SHORT CICUITING.
=======================================================
Regulatory Information
=======================================================
Federal Regulatory Information: ALL NICKEL CADMIUM BATTERIES ARE CLASSIFIED AS
D006 HAZARDOUS WASTE BECAUSE OF THE PRESENCE OF CADMIUM. THIS WASTE CODE IS
ASSIGNED BECAUSE OF TOXICITY, NOT CORROSIVENESS. THESE BATTERIES DO NOT MEET
THE DEFINITION OF A CORROSIVE WASTE.
=======================================================
Other Information
=======================================================
Other Information: NICKEL CADMIUM BATTERIES DESTINED FOR RECYCLING CAN BE
MANAGED UNDER THE FEDERAL UNIVERSAL WASTE RULE CODIFIED IN 40 CFR PART 273.
=======================================================
Transportation Information
=======================================================
Trans ID NO: 154658
Product ID: NICKEL CADMIUM BATTERIES (NICD) ALL MODELS/SIZES
Review Date: 09/11/2000
Net Unit Weight: UNKNOWN
Multiple KIT Number: 0
Unit Of Issue: EA
Container QTY: 0
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: NICKEL CADMIUM BATTERIES (NICD) ALL MODELS/SIZES
Cage: 0J4G8
Company Name: PANASONIC INDUSTRIAL CO DIV OF MATSUSHITA ELECT CORP OF AMER
Street: TWO PANASONIC WAY
Zipcode: 07094
Date Of Label Review: 09/11/2000
Status Code: A
Origination Code: F
Signal Word: NONE
Health Hazard: None
Contact Hazard: None
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: NICKEL CADMIUM BATTERIES DO NOT LEAK ELECTROLYTE UNDER
NORMAL USAGE CONDITIONS. SEVERELY OVERCHARGED OR ABUSED BATTERIES MAY LEAK
SMALL AMOUNTS OF ELECTROLYTE. THE BATTERIES REFERENCED HEREIN ARE EXEM PT
ARTICLES AND ARE NOT SUBJECT TO THE OSHA HAZARD COMMUNICATION STANDARD
REQUIREMENT. THIS SHEET IS PROVIDED AS A SERVICE TO OUR CUSTOMERS.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:GARON PLUG
CAGE:2N005
CAGE:2N005
============= Composition/Information on Ingredients =============
Ingred Name:CALCIUM ALUMINATES
Ingred Name:FERRITE(S)
CAS:1317-54-0
RTECS #:LK0495000
Ingred Name:SILICATE(S)
CAS:14407-96-6
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NONE
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:NONE. EYE:FLUSH W/WATER FOR AT LEAST 15 MINUTES, CALL MD .
SKIN:WASH W/POTABLE WATER, CALL MD . INHAL: REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O2/ARTF RESP), CALL MD . INGEST:C ALL MD
IMMEDIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
================== Accidental Release Measures ==================
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE. USE NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:RUBBER APRON.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:3-3.2
Solubility in Water:NOT SOLUBLE
Appearance and Odor:LIGHT TAN POWDER, NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, CITY, STATE AND FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PHOSPHATE CHEMETS, VACUETTES & VACAVIALS, R
CAGE:7K791
CAGE:7K791
============= Composition/Information on Ingredients =============
Ingred Name:MOLYBDIC ACID, HEXAMMONIUM SALT (AMMONIUM MOLYBDATE)
CAS:12027-67-7
RTECS #:QA5076000
Fraction by Wt: <1.0%
Ingred Name:SULFURIC ACID (SARA III)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 5.0%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:DEIONIZED WATER
CAS:77-18-5
Fraction by Wt: >94.0%
Ingred Name:THE FOLLOWING PHYSICAL, HEALTH, FIRE ETC. DATA IS PROVIDED
FOR INGREDIENT 02 (SULFURIC ACID).
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:MAY CAUSE IRRITATION,
CONJUNCTIVITIS AND LACRIMATION. SKIN:MAY CAUSE IRRITATION AND
DERMATITIS. COULD CAUSE SEVERE BURNS. INHAL:MAY CAUSE COUGHING AND
IRRITATION OF THE UPPER RESPIRATORY TRACT. IN GEST:MAY CAUSE BURNS
OF THE MUCOUS MEMBRANES OF THE THROAT, ESOPHAGUS AND STOMACH.
Explanation of Carcinogenicity:NONE SPECIFIED BY MANUFACTURER.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH CONTINUOUSLY W/COPIOUS AMTS OF WATER FOR AT LEAST
15 MINS. FORCIBLY HOLD EYELIDS APART TO ENSURE IRRIGATION OF ALL
EYE/LID TISSUE. SEEK PROMPT MED ATTN. SKIN:WASH AFFECTED AREAS
W/SOAP/MILD DETERGENT & LGE AMTS OF WATER. IN CASE OF CHEM BURNS,
COVER AREA W/STERILE DRY DRESSING. SEEK PROMPT MED ATTN. INHAL:
REMOVE INDIVIDUAL TO FRESH AIR IMMED. SUPPORT BRTHG (GIVE O*2/ (SEE
SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:DRY CHEMICAL OR CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP COMBUSTIBLES AWAY FROM SPILLED MATERIAL.
DO NOT TOUCH SPILLED MATERIAL. TAKE UP W/SAND OR OTHER ABSORBENT
MATERIAL & PLACE INTO SMALL CONTAINERS FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:WEAR EYE AND SKIN PROTECTION.
VENTILATION RECOMMENDED.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST VENTILATION.
Other Protective Equipment:IMPERVIOUS CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC:ART RESP) . SEEK PROMPT MED ATTN. INGEST:IF VICTIM IS
CONSCIOUS AND NOT CONVULSIVE, IMMEDIATELY GIVE THE VICTIM LARGE
QUANTITIES OF WATER TO RINSE THE MOUTH. THEN GIVE MILK MIXED W/EGG
WHITES TO DRINK. DO NOT INDUCE VOMITING. SEEK PROMPT MED ATTN.
================== Physical/Chemical Properties ==================
HCC:C2
Boiling Pt:B.P. Text:536F,280C
Melt/Freeze Pt:M.P/F.P Text:37.0F,2.8C
Vapor Pres:0.001@20C
Vapor Density:3.4
Spec Gravity:1.8
Solubility in Water:SOLUBLE
Appearance and Odor:LIQUID, COLORLESS TO DARK BROWN, OILY
================= Stability and Reactivity Data =================
VIOLENT EXOTHERMIC REACTION W/WATER OR STEAM AND ORGANIC MATERIALS.
COULD IGNITE FINELY DIVIDED COMBUSTIBLE MATERIALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCTS INCLUDE
HIGHLY TOXIC FUMES OF SULFUR OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF BY MEANS AS TO COMPLY W/ALL LOCAL,
STATE AND FEDERAL REGULATIONS OR CONTACT AN APPROVED AND LICENSED
DISPOSAL AGENCY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:POR-SEP RELEASE, 578000
CAGE:79717
CAGE:79717
============= Composition/Information on Ingredients =============
Ingred Name:PEPPERMINT OIL
Ingred Name:VEGETABLE OIL
OSHA PEL:15 MG/M3 MISTS
ACGIH TLV:10 MG/M3 MISTS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMEDIATELY . INHAL: REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTIFICIAL RESPIRATION) CALL MD . EYES:
IMMEDIATELY FLUSH W/POTABLE WATER FOR A MINIMUM OF 15 MINUTES,
SEEK ASSISTANCE FROM MD . SKIN: FLUSH W/COPIOUS AMOUNTS OF WATER.
CALL MD. .
===================== Fire Fighting Measures =====================
Extinguishing Media:NOT APPLICABLE. USE MEDIA SUITABLE FOR SURROUNDING
FIRE .
Fire Fighting Procedures:NOT APPLICABLE. WEAR NIOSH/MSHA APPROVED SCBA
AND FULL PROTECTIVE EQUIPMENT .
================== Accidental Release Measures ==================
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM IGNITION SOURCES.
PROTECT FROM HIGH HEAT. KEEP CONTAINERS CLOSED WHEN NOT IN USE.
Other Precautions:NOT APPLICABLE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED. NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Other Protective Equipment:NONE
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:WATER CLEAR ALCOHOLIC SOLUTION. SLIGHT AMMONIA
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:NOT APPLICABLE. DISPOSE OF I/A/W FEDERAL, STATE,
AND LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:REPRODOT DEVELOPER/REPLENISHER CONCENTRATE, 423-0101
CAGE:61263
CAGE:61263
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM SULFITE (2:1)
CAS:7757-83-7
RTECS #:WE2150000
Fraction by Wt: 10-15%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POTASSIUM CARBONATE (2:1)LD50: (ORAL, RAT) 1,870 MG/KG
CAS:584-08-7
RTECS #:TS7750000
Fraction by Wt: 5-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:HYDROQUINONE (SARA 302/313) (CERCLA)
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: 3-7%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SODIUM HYDROXIDE (CERCLA)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 1-5%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3, C
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 70-80%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACETIC ACID, (ETHYLENEDINITRILO) TETRA-;
(ETHYLENEDIAMINE-TETRAACETIC ACID) (EDTA) (CERCLA)
CAS:60-00-4
RTECS #:AH4025000
Fraction by Wt: 0.16%
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VENT: VENT REQS. ACCEPTED PRACTICE IS TO PROVIDE GEN VENT
AT RATE OF AT LEAST 10 AIR CHANGES PER HOUR. IF (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: PHOTOPROCESSOR HAS LOCAL EXHAUST CONNECTION, IT
SHOULD BE VENTED TO OUTDOORS.
RTECS #:9999999ZZ
Ingred Name:EYE PROT: & FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 2
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DANGER! PROD IS CORR; BURNS EYE TISS
ON CNTCT. SKIN CNTCT MAY RSLT IN IRRIT/ALLERGIC RXN IN SENSITIVE
PERS W/PAIN, REDNESS, ITCH & IRRIT OF CNTCTD SKIN. AVOID SKIN
CNTCT. INHAL EXPOS TO MISTS/SPRAY CO ULD CAUSE ALLERGIC ASTHMA RXN
W/DFCLTY BRTHG & CONSTRICTION OF BRTHG PASSAGES. EFTS OF CHRONIC
EXPOS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: TO MIX OF CHEMS IN PROD ARE UNKNOWN.
NO DATA ON REPRO EFTS IN HUMANS. HYDROQUINONE WAS NOT TERATOGENIC
WHEN GIVEN ORALLY TO PREGNANT RABBITS BUT DID CAUSE EFTS ON MALE
FERTILITY IN MALE RATS EXPOS FOR 51 DAYS TO HIGH ORAL DOSES.
SODIUM SULFITE & HYDROQUINONE TESTED POS IN VARIOUS SHORT TERM
GENOTOX TESTS.
Medical Cond Aggravated by Exposure:PERSONS WITH ASTHMA OR OTHER
ALLERGIC CONDITIONS (ESPECIALLY KNOWN ALLERGY TO SULFITES) MAY BE
SENSITIVE TO THIS PRODUCT. OTHER SKIN CONDITIONS MAY BE AGGRAVATED
AS WELL.
======================= First Aid Measures =======================
First Aid:EYES: IMMED FLUSH W/LG AMTS OF WATER FOR AT LEAST 15 MIN,
OCCAS LIFT UPPER & LOWER EYELIDS. CONSULT MD IMMED. SKIN: WASH
CONTAMD SKIN W/SOAP & WATER. IF CLTHG BECOMES CONTAMD, REMOVE IMMED
& LAUNDER B EFORE REUSE. IF IRRIT/PAIN DEVELOPS, GET MED ATTN.
INHAL: MOVE TO FRESH AIR UNTIL SYMPS DISAPPEAR. IF BRTHG IS DFCLT,
ADMIN OXYGEN & CALL MD. ENSURE ADEQ VENT TO PVNT VAPS FROM ACCUM
BEFORE (SUPDAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER MIST, ALCOHOL FOAM, CARBON DIOXIDE BLANKET.
USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING MATERIALS.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . COOL CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:CAN EVOLVE TOXIC GASES (SO*X) WHEN
HEATED.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL & NEUTRALIZE W/WEAK ACID OR
BICARBONATE. SMALLER SPILLS CAN BE ABSORBED W/VERMICULITE OR OTHER
ABSORBENT MATERIALS. USE PROTECTIVE EQUIPMENT TO PREVENT SKIN & EYE
EXPOSURE DURING CLEANUP .
Neutralizing Agent:NEUTRALIZE WITH WEAK ACID OR BICARBONATE.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT FROM TEMPERATURE EXTREMES.
STORE AND SHIP ABOVE 40F (5C) AND BELOW 100F (40C). OPTIMUM STORAGE
TEMPERATURE: 68F (20C).
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO ADDNL RESP PROT SHOULD BE NEEDED IF
SUFFICIENT VENT IS PROVIDED. IF THERE IS POSS THAT AIRBORNE CONC
MAY EXCEED ALLOWABLE LIMS, RESP EQUIPPED W/NIOSH/MSHA APPRVD ACID
GAS/ORG VAP CARTRIDGES SHOULD BE WORN. CONSULT RESP MFR FOR
(SUPDAT)
Ventilation:MECH VENT SHOULD BE USED TO CTL AIRBORNE CONTAMINANT
LEVELS. REFER TO PHOTOPROCESSOR EQUIP MANUAL FOR SPECIFIC (ING 7)
Other Protective Equipment:EMERGENCY EYE WASH. WEAR PROTECTIVE COVERING
(CHEMICAL APRON) TO PREVENT SKIN CONTACT. ANSI APPRVD DELUGE SHOWER
.
Work Hygienic Practices:USE GOOD INDUS HYGIENE PRACT (WASH HANDS AFTER
USE) TO PVNT SKIN IRRIT. IF CLTHG CONTAMD, REMOVE & LAUNDER BEFORE
REUSE.
Supplemental Safety and Health
FIRST AID PROC: RETURNING TO WORK. INGEST: CNTCT MD IMMED. ADMIN ONE OR
TWO GLASSES OF WATER, BUT DO NOT GIVE ANYTHING BY MOUTH IF PERSON
IS HAVING CONVLS OR IS UNCON. DO NOT INDUCE VOMIT. RESP PROT: RESP
LIMITATIONS. IF RESPS ARE WORN, COMPLY W/OSHA REQS 29 CFR 1910.134
FOR RESP PROT PROGRAM.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:220F,104C
Spec Gravity:1.2
pH:12.3
Solubility in Water:COMPLETE (20C)
Appearance and Odor:LIGHT YELLOW LIQUID; SLIGHT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH ACIDS.
Stability Condition to Avoid:AVOID HEATING PRODUCT.
Hazardous Decomposition Products:SO*X.
==================== Disposal Considerations ====================
Waste Disposal Methods:PROD SHOULD BE DISPOSED OF I/A/W FED (40 CFR
PART 261), STATE & LOCAL REGS. BEFORE ATTEMTPING CLEANUP, REFER TO
HAZ INFO & PROT MEASURES. HYDROQUINONE & SODIUM HYDROXIDE ARE TOX
TO AQUATIC LIFE. DO NO T DISPOSE OF THIS PROD IN WATERWAYS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CAUSTIC SODA, LIQUID
CAGE:GO410
CAGE:GO410
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE
CAS:1310-73-2
RTECS #:WB4900000
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3, C
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SPILL PROC: RECOVER. DIKE LARGE SPILLS AND RECOVER.
CAUTION: APPLYING WATER TO CAUSTIC SODA MAY CAUSE (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2:SPLATTERING. WEAR FULL PROT CLTHG. IF MIST IS
PRESENT, WEAR NIOSH/MSHA APPRVD SCBA.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CORR. SEVERE BURNS TO EYES,
POSSIBLE BLINDNESS, SEVERE BURNS TO SKIN. IMMED TREATMENT IS
NECESSARY! MAY BE HARMFUL IF INHALED. INGESTION DAMAGES MUCOUS
MEMBRANES AND TISSUES OF GASTRO-INTESTINA L TRACT.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:IMMED & CONTINUOUSLY IRRIGATE W/FLOWING WATER FOR @ LST
30 MIN. HOLD LIDS OPEN TO INSURE COMPLETE IRRIGATION OF ALL LID &
EYE TISSUE. GET IMMED MED ATTN. DO NOT WEAR CONT LENSES WHEN
WORKING W/CAU STIC SODA. SKIN: IMMED FLUSH W/WATER FOR @ LST 30 MIN
WHILE REMOVING CONTAMD CLTHG. PROMPT MED ATTN IS ESSNTL FOR TRTMT
OF BURNS. INHAL: REMOVE TO FRESH AIR. IF BRTHG HAS STOPPED, PERFORM
PULM(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:USE EXTINGUISHER DESIGNED FOR SURROUNDINGS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . WILL NOT BURN. DIKE LIQ RUNOFF. APPLYING
WATER MAY CAUSE SPATTERING OF CORR LIQ.
Unusual Fire/Explosion Hazard:NON-FLAMMABLE, BUT WILL RELEASE FLAMMABLE
HYDROGEN GAS WHEN IN CONTACT WITH ALUMINUM, TIN, ZINC AND THEIR
ALLOYS. REACTS W/HYDROCARBONS.
================== Accidental Release Measures ==================
Spill Release Procedures:CORR. KEEP UPWIND. ISOLATE AREA & DENT ENTRY.
DO NOT GET IN EYES, ON SKIN/CLTHG. DO NOT BREATHE MIST, IF ANY.
SHUT OFF LEAK IF W/OUT RISK. MAY BE A SLIPPING HAZ. PVNT ENTRY INTO
SEWERS/NATURAL WATERS. USE SAND/OTHER ABSORB ON SM SPILLS, & (ING
2)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:WEAR PROT EQUIP IN HANDLING PRODUCT.
STORE SEPARATELY FROM ACIDS, METALS, CHLOROCARBONS, NITROCARBONS.
STOR AREA SHOULD HAVE CONTROLLED DRAINAGE.
Other Precautions:WATER SUPPLY FOR DILUTION OF SPILLS DESIRABLE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED FILTER-TYPE RESPIRATORY
EQUIPMENT FOR MIST PROTECTION.
Ventilation:GENERAL ROOM VENTILATION TO CONTROL MIST.
Other Protective Equipment:RUBBER SAFETY TOE SHOES/BOOTS. OTHER
APPROPRIATE CLOTHING AND/OR EQUIPMENT. EMER EYEWASH & DELUGE SHOWER
.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPEC GRAV:1.5(50%SOL) 12.8 LBS/GAL. % VOLAT: (NOT VOLAT) DUST/MISTS 2
MG/CUBIC METER OF AIR. FIRST AID PROC: RESUSCITATION. LOOK OUT FOR
SHOCK. GET MED AID. INGEST:DILUTE BY DRINKING WATER/MILK-DO NOT
INDUCE VOMIT. FOLLOWING DILUT, FRUIT JUICE/VINEGAR MAY BE
ADMINISTERD TO NEUT CAUSTIC. EYE PROT: FULL LGTH FSHLD.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:288F,142C
Melt/Freeze Pt:M.P/F.P Text:68.0F,20.0C
Spec Gravity:SUPP DATA
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, SLIGHTLY VISCOUS LIQUID, NO ODOR
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, CHLORINATED SOLVENTS: STRONG RXN, PERHAPS RESULTING IN FIRE.
Stability Condition to Avoid:WATER.
Hazardous Decomposition Products:ALUMINUN, ZINC, GALVANIZING.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT SUPPLIER AND AUTHORITIES. DISPOSE OF
I/A/W FEDERAL, STATE AND LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:5183 BARE WIRE ALUMINUM ALLOY
CAGE:0ACE2
CAGE:0ACE2
============= Composition/Information on Ingredients =============
Ingred Name:CHROMIUM METAL, CHROMIUM, CHROME (KNOWN CARCINOGEN BY NTP;
IARC CARC - GROUP 3) *95-4*
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 0-0.25%
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ZINC OXIDE *95-4*
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: 0.25%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM FUME
Ingred Name:THALLIUM
CAS:7440-28-0
RTECS #:XG3425000
Fraction by Wt: 0.15%
OSHA PEL:0.1 MG/CUM
ACGIH TLV:0.1 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ALUMINUM (POWDER) *95-4*
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 92.2-94%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:AMORPHOUS FUSED SILICA, SILICON DIOXIDE, QUARTZ, SILICON
(SUSPECTED HUMAN CARCINOGEN BY IARC - GROUP 2A) *95-4*
CAS:60676-86-0
RTECS #:VV7328000
Fraction by Wt: 0.4%
Other REC Limits:30 MG/CUM TOTAL DUST
ACGIH TLV:0.1 MG/CUM (RESP) IC
Ingred Name:RED IRON OXIDE/IRON (III) OXIDE/FERRIC OXIDE/YELLOW FERRIC
OXIDE/YELLOW IRON OXIDE/IRON OXIDE PIGMENT
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 0.4%
OSHA PEL:10 MG/CUM
ACGIH TLV:5 MG/CUM (FE)
Ingred Name:COPPER (DUST & MIST), BRONZE POWDER *95-4*
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 0.1%
Other REC Limits:1 MG(CU)/M3 (DUST)
OSHA PEL:0.1 MG(CU)/M3 (FUME)
ACGIH TLV:0.2 MG/M3 (FUME)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:MANGANESE, MN COMPOUNDS
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 0.5-1%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM (DUST)
Ingred Name:MAGNESIUM OXIDE, MAGNESIA
CAS:1309-48-4
RTECS #:OM3850000
Fraction by Wt: 4.3-5.2%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SHORT TERM EXPOSURE TO WELDING FUME
MAY CAUSE IRRITATION OF THE THROAT. LONG TERM EXPOSURE TO WELDING
FUME, GASES/DUST MAY CONTRIBUTE TO PULMONARY
IRRITATION/PNEUMOCONIOSIS. LONG TERM EXPOSURE TO IRON FUME MAY
PRODUCE SIDEROSIS. BURNS FROMELECTROMAGNETIC RADIATION.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:SHORT TERM EXPOSURE TO WELDING FUME:
DISCOMFORT, DIZZINESS, NAUSEA, DRYNESS, IRRITATION.
Medical Cond Aggravated by Exposure:IMPAIRED PULMONARY
FUNCTION/ILLNESS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR IF NEEDED. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONCOMBUSTIBLE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:METAL POWDER FIRE: USE DRY SAND, DRY GRAPHITE/OTHER
CLASS D FIRE EXTINGUISHING POWDER.
Fire Fighting Procedures:IF MATERIAL IS REDUCED TO POWDER FORM, CAUTION
MUST BE USED TO PREVENT FIRE/EXPLOSION.
Unusual Fire/Explosion Hazard:CONTACT W/MINERAL ACIDS & OXIDIZING
AGENTS MAY GENERATE HYDROGEN GAS WHICH MAY BE AN EXPLOSION HAZARD.
======================Handling and Storage ======================
Handling and Storage Precautions:WEAR APPROPRIATE EQUIPMENT TO PREVENT
INJURY FROM RADIATION/SPARKS/ELECTRIC SHOCK. TRAIN THE EMPLOYEE TO
KEEP HEAD OUT OFUMES.
Other Precautions:USE EXHAUST SYSTEM TO CLEAR WELDING FUMES. MAKE SURE
THAT INHALED AIR DOESN'T CONTAIN FUME CONSTITUENTS ABOVE
PERMISSABLE LEVELS. TRAIN WELDER NOT TO TOUCH LIVE ELECTRICAL PARTS
& INSULATE HIMSELF FRO M WORK & GROUND.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRABLE FUME RESPIRATOR/AIR SUPPLIED
RESPIRATOR WHEN WELDING, BRAZING/SOLDERING IN CONFINED SPACES/WHERE
LOCAL EXHAUST/VENTILATION DOESN'T KEEP EXPOSURE BELOW PELS,
TLVS/STELS.
Ventilation:USE LOCAL EXHAUST AT THE ARC/FLAME TO KEEP FUMES & GASES
BELOW PELS, TLVS/STELS IN WORKERS BREATHING ZONE/GENERAL AREA.
ARM PROTECTORS/APRONS/HATS/SHOULDER PROTECTION/DARK SUBSTANTIAL
CLOTHING.
Work Hygienic Practices:WELDER'S SHOULDN'T WEAR SHORT SLEEVES
SHIRTS/SHORT PANTS/CUTOFFS.
Supplemental Safety and Health
PRODUCT IS NON-HAZARDOUS UNTIL USED AS IN WELDING PURPOSE. THE
COMPOSITION & QUANTITY OF FUMES/GASES DEPENDS ON METAL BEING
WELDED, PROCESS, PROCEDURES, ELECTRODES USED, COATING, POSITION OF
WELDERS H EAD W/RESPECT TO THE FUME PLUME & AS WELL AS THE PRESENCE
OF CONTAMINANTS IN THE ATMOSPHERE.
================== Physical/Chemical Properties ==================
Appearance and Odor:SOLID WIRE/ROD, GREY TO SILVER IN COLOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONTACT W/MINERAL ACIDS & OXIDIZING AGENTS MAY GENERATE HYDROGEN GAS.
Stability Condition to Avoid:(SEE SUPP)
Hazardous Decomposition Products:VARIOUS ELEMENTAL METALS & METAL
OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSABLE
CONTAINER/LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER
IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PR-1440 B-2, BASE
Preparer's Name:SEROJE HARTOONIANI
CAGE:83574
CAGE:83574
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM DIOXIDE (LISTED AS REQ'D BY 29 CFR1910.1200, FULLY
ENCAPSULATED, NOT HAZARDOUS UNDER NORMAL CIRCUMSTANCES)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 3.140%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:CALCIUM CARBONATE(LIMESTONE)(LISTED AS REQ'D BY 29CFR
1910:1200,FULLY ENCAPSULATD,NOT HZDOUS UNDER NORMAL CIRCUMSTANCES)
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 30.421%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15.0 MG/M3
ACGIH TLV:10.0 MG/M3
Ingred Name:TOLUENE (SARA III) (VAPOR PRESSURE 23 MM HG)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 0.978%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM;STEL 150 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:POLYSULFIDE POLYMER (NON HAZARDOUS INGREDIENT)
CAS:68611-50-7
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICA DERIVATIVES (NON HAZARDOUS INGREDIENT)
CAS:67762-90-7
Other REC Limits:NONE RECOMMENDED
Ingred Name:VOC PER EPA METHOD 24: 35 G/L (COMBINED PART A & B)
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MAY CAUSE BURNING, TEARING,
REDDENING. SKIN: PROLONGED EXPOSURE MAY CAUSE DRYING & CRACKING OF
SKIN & DERMATITIS. INHALATION: MAY CAUSE DIZZINESSS, DROWSINESS, &
FATIGUE. MAY CAUSE LIVER & KIDNE Y DAMAGE. INGESTION: DROWSINESS,
DIZZINESS, & NAUSEA. CHRONIC: DISTURBANCE IN MEMORY, THINKING,
EMOTIONS & COORDINATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER. IF SYMPTOMS PERSIST, CONSULT A
PHYSICIAN. SKIN: WASH WITH SOAP AND WATER. IF SYMPTOMS PERSISTS,
CONSULT A PHYSICIAN. INHALATION: REMOVE TO FRESH AIR. IF SYMPTOMS
ARE PRESENT, C ONSULT A PHYSICIAN. INGESTION: DRINK LARGE AMOUNTS
OF WATER; INDUCE VOMITING; CONSULT A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:>200F,>93C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER SPRAY.
Fire Fighting Procedures:USE AIR SUPPLIED RESPIRATOR.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP INTO CONTAINERS. CLEAN-UP RESIDUE WITH A
SUITABLE SOLVENT. CERCLA RQ FOR TOLUENE IS 1,000 LBS.
======================Handling and Storage ======================
Handling and Storage Precautions:WASH THOROUGHLY AFTER HANDLING AND
BEFORE SMOKING OR EATING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:GENERAL VENTILATION.
Other Protective Equipment:NONE KNOWN
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
SMOKING OR EATING.
Supplemental Safety and Health
KEY1:N1.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:230 TO 350F
Vapor Density:> AIR
Spec Gravity:1.571
Viscosity:10500P#7@2RPM
Evaporation Rate & Reference:< N-BUTYL ACETATE
Solubility in Water:SLIGHT
Appearance and Odor:BEIGE THIXOTROPIC PASTE
Percent Volatiles by Volume:3.3
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NOT KNOWN
Hazardous Decomposition Products:OXIDES OF CARBON, SULFUR DIOXIDE,
TRACES OF HYDROGEN SULFIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:NOT A HAZARDOUS WASTE ACCORDING TO EPA
REGULATIONS. CONSULT STATE REGULATIONS PRIOR TO DISPOSAL OF
SPILLAGE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:3012301,VV-L-800C AM.1 (OCTOIL 90-2)
Preparer's Name:J.J. BURGARD
CAGE:82925
CAGE:82925
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM HYDROCARBONS
Fraction by Wt: MAJOR
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV FOR OIL MIST IS 5MG/M3
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:MAY CAUSE SLIGHT
IRRITATION.SKIN:MAY CAUSE MODERATE IRRITATION.INGEST:PRACTICALLY
NON-TOXIC.MAY CAUSE SLIGHT GI TRACT IRRITATION.INHAL:NO ADVERSE
EFFECTS EXPECTED.INJECTION OF OIL UNDER THE SKIN MAY CAUSE
NECROSIS, AND IS A MEDICAL EMERGENCY.
Explanation of Carcinogenicity:NONE OF THE INGREDIENTS IN THIS PRODUCT
IS LISTED BY NTP, IARC OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYES:REDNESS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. IF
IRRITATION PERSISTS, SEE DOCTOR. SKIN: WASH WITH MILD SOAP. IF
IRRITATION PERSISTS, SEE DOCTOR. INHALATION: NONE NORMALLY
REQUIRED. INGESTI ON: SEE DOCTOR. IF CONSCIOUS,GIVE LIQUIDS AND
INDUCE VOMITING. INJECTION: THIS IS A MEDICAL EMERGENCY. SEE DOCTOR
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:320F,160C
Lower Limits:1.0
Upper Limits:7.0
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL. DO NOT USE A DIRECT STREAM OF WATER;PRODUCT FLOATS & CAN
REIGNITE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP WITH NON-COMBUSTIBLE INERT
ADSORBANT(EG.CLAY);PLACE COLLECTED MATERIAL IN AN APPROPRIATE
CONTAINER FOR DISPOSAL;CLEAN SPILL AREA TO REMOVE
SLIPPERINESS.AVOID RUNOFF INTO WATER WAYS.REPORT SPIL LS RESULTING
IN SHEEN UPON WATER TO 800-424-8802.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP AWAY FROM HEAT, OPEN FLAMES AND STRONG
OXIDANTS. KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:AVOID EYE AND SKIN CONTACT. DO NOT BREATHE VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE ENVIRONMENTAL CONTROLS ARE LACKING OR IN
ENCLOSED SPACES USE A NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC
VAPORS.
Ventilation:USE FORCED AIR VENTILATION.
Other Protective Equipment:PROTECTIVE CLOTHING AS REQUIRED TO MINIMIZE
EXPOSURE FROM PROLONGED OR REPEATED CONTACT. EYE BATH AND SAFETY
SHOWER.
Work Hygienic Practices:WASH HANDS.SEPERATE WORK CLOTHES FROM STREET
CLOTHES.LAUNDER WORK CLOTHES BEFORE REUSE.KEEP FOOD OUT OF THE WORK
AREA.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:550F,288C
Vapor Pres:<0.01
Spec Gravity:0.89
Evaporation Rate & Reference:<0.01 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT STRAW COLORED LIQUID,SLIGHT PETROLEUM ODOR.
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:AIRBORNE SOLID AND LIQUID
PARTICULATES, CARBON MONOXIDE, OTHER UNIDENTIFIED HYDROCARBON
PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:RECYCLE WASTE WHERE APPLICABLE. CONTACT YOUR
LOCAL ENVIRONMENTAL OFFICER. DISPOSE OF IN ACCORDANCE WITH ALL
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DEVRAN 234 QC BUFF BASE, 234B1642
Kit Part:Y
CAGE:1HK86
CAGE:1HK86
============= Composition/Information on Ingredients =============
Ingred Name:ING 17: CNTNS A CHEM KNOWN TO THE STATE OF CA TO CAUSE
CANCER, BIRTH DEFECTS, OR OTHER REPRODUCTIVE HARM(PROPOSITION 65)
RTECS #:9999999ZZ
Ingred Name:RESP PROT: & SANDING DUST. FOR RESTRICTED VENT AREAS, WEAR
NIOSH/MSHA APPRVD CHEM/MECH FILTER DESIGNED TO (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19: REMOVE A COMBINATION OF PARTICULATES & VAPOR. WHEN
USED IN CONFINED AREAS, WEAR NIOSH/MSHA APPRVD AIR (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20: SUPPLY RESP OR USE HOODS. USE NIOSH/MSHA APPRVD
RESP WHEN FLAME CUTTING/WELDING/BRAZING AND SANDING MATL(ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21: COATED WITH THIS PRODUCT.
RTECS #:9999999ZZ
Ingred Name:VENT: APPLICABLE SAFETY & HLTH STANDARDS IN THE MIXING,
APPLICATION & CURING AREAS & TO REMOVE SANDING DUSTS OF (ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23: DRIED COATINGS & DECOMP PROD DURING WELDING & FLAME
CUTTING ON SURFACES COATED W/PROD. VAPS MAY SPREAD (ING 25)
RTECS #:9999999ZZ
Ingred Name:ING 24:LONG DISTANCES. PVNT BUILD-UP REMOVING HEAVY SOLV
VAPS FROM LOWER LEVELS OF THE WORK AREA.
RTECS #:9999999ZZ
Ingred Name:EPOXY FLEXIBILIZER. VP: <0.001
Fraction by Wt: < 5%
OSHA PEL:0.02 PPM (MFR)
ACGIH TLV:0.005 PPM (MFR)
Ingred Name:HYDROCARBON RESIN (PROPRIETARY INGREDIENT)
Fraction by Wt: 5%
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:INERT PIGMENT
Fraction by Wt: 10%
OSHA PEL:20 MPPCF (MFR)
ACGIH TLV:3 MG/M3 (MFR)
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 25%
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:BUTYL ALCOHOL; (N-BUTYL ALCOHOL) VP: 5.9 LD50:(ORAL,RAT)
2.5 GM/KG
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 10%
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENE VP: 6. LD50:(ORAL,RAT) > 5 GM/KG
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 5%
OSHA PEL:100 PPM;150 PPM STEL
ACGIH TLV:100 PPM;150 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:2-HEPTANONE; (METHYL N-AMYL KETONE) VP: 4.LD50:
(ORAL,RAT) 1600 MG/KG
CAS:110-43-0
RTECS #:MJ5075000
Fraction by Wt: < 5%
OSHA PEL:100 PPM
ACGIH TLV:50 PPM
Ingred Name:SUPP DATA: MAY IGNITE. DURING EMERGENCY CONDITIONS OVEREXP
TO DECOMP PROD MAY CAUSE A HLTH HAZ. SYMP MAY NOT BE (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: IMMEDIATELY APPARENT. OBTAIN MED ATTENTION.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: DO NOT INDUCE VOMITING. ASPIRATION OF
VOMITUS CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL.(ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: NOTICE: INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING AND INHALING THE CONTENTS MAY BE HARMFUL OR FATAL.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: MAINTAINING CONTINUOUS FLOW OF FRESH AIR. STORE
LARGE QTYS IN BLDG TO COMPLY WITH OSHA 1910.106. (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: KEEP CONTAINER CLOSED WHEN NOT IN USE. DO NOT
TRANSFER CONTENTS TO BOTTLES/OTHER UNLABELED CONTAINERS.(ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: DO NOT REUSE EMPTY CONTAINERS. IF THIS MATL IS PART
OF A 2 COMPONENT PROD, THEN THE MIXTURE OF BASE & (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: CONVERTER PORTIONS WILL HAVE HAZ OF BOTH
COMPONENTS. OBSERVE ALL APPLICABLE PREC. WARNING: THIS PROD (ING
18)
RTECS #:9999999ZZ
Ingred Name:EPOXY RESIN (MIXTURE) LD50:(ORAL,RAT) > 4000 MG/KG
Fraction by Wt: 25%
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: IRRIT OF RESP TRACT; HEADACHE,
NAUSEA, DIZZ, WEAKNESS & FATIGUE. EXTREME EXPOSURE CAN RESULT IN
UNCON & EVEN RESP ARREST. MAY CAUSE ALLERGIC RXN. OVEREXP MAY CAUSE
PERMANENT LUNG DAMAGE. SKIN/E YE: CAUSES EYE & SKIN IRRIT. MAY BE
HARMFUL IF ABSORBED THRU SKIN. INGEST: CAN CAUSE STOMACH &/OR (SEE
EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: INTESTINAL IRRIT, NAUSEA, VOMITING &
DIARRHEA. CHRONIC: REPORTS HAVE ASSOC REPEATED & PROLONGED
OCCUPATIONAL OVEREXP TO SOLVENTS WITH PERMANENT BRAIN & NERVOUS
SYSTEM DAMAGE. PROLONGED/REPEA TED BREATHING OF SPRAY MIST AND/OR
SANDING DUST OVER A PERIOD OF YEARS MAY CAUSE DUST DISEASE OF THE
LUNGS.
Medical Cond Aggravated by Exposure:NONE, WHEN USED IN ACCORDANCE WITH
SAFE HANDLING AND USE INFORMATION.
======================= First Aid Measures =======================
First Aid:INHAL: IF DIFFICULTY BREATHING, LEAVE THE AREA TO OBTAIN
FRESH AIR. IF CONTINUED DIFFICULTY, GET MED ATTN IMMED. IF
BREATHING CEASES, RESTORE USING APPRVD CPR TECHNIQUES & GET MED
ATTN IMMED. EYES: FL USH IMMED W/LRG AMTS OF WATER FOR AT LEAST 15
MIN. GET MED ATTN. SKIN: WASH AFFECTED AREAS WITH SOAP AND WATER.
REMOVE SOILED CLOTHING. GET MED ATTN IF IRRIT PERSISTS. INGEST: SEE
MD IMMED. (ING 12)
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:80.0F,26.7C
Lower Limits:1 %
Extinguishing Media:IN CASE OF FIRE USE CO*2 DRY CHEM, FOAM/OTHER
NATIONAL FIRE PROT ASSOC (NFPA) APPRVD METHOD FOR TREATING A CLASS
B FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . WATER SPRAY MAY BE INEFT. IF WATER SPRAY IS
USED, FOG NOZZLES (SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT/ELEC EQUIP/SPARKS & FLAME. VAPS MAY CAUSE FLASH FIRE. VAPS MAY
IGNITE EXPLOSIVELY. VAPS MAY SPREAD LONG (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT. PREVENT BRTHG OF
VAPS. VENT AREA. BEFORE ATTEMPTING CLEAN-UP, REFER HNDLG/STOR PREC
IN OTHER SECTIONS OF MSDS. CNTN SPILLED MATL & REMOVE W/INERT
ABSORB & NON-SPARKING TOO LS. STORE IN CLSD CNTNR UNTIL PROPERLY
DISPOSED OF
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT/SPARKS & FLAMES.
DO NOT SMOKE. DO NOT STORE ABOVE 120 F/NEAR FIRE/OPEN FLAME. VAPS
MAY SPREAD LONG DISTANCE & BEYOND CLSD DOORS.
Other Precautions:EXTINGUISH ALL PILOT LIGHTS & TURN OFF ALL SOURCES OF
IGNIT INCLUDING HEATERS/FANS & OTHER NON-EXPLOSION-PROOF ELECTRICAL
EQUIPMENT, DURING USE & UNTIL ALL VAPS ARE GONE. VAPS MAY IGNITE
EXPLOSIVELY. PREVENT BUILD-UP OF VAPS BY (ING 14)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DO NOT BREATHE VAPS, SPRAY MIST/SANDING DUST.
WHEN SPRAY APPLIED IN OUTDOOR OR OPEN AREAS, AND DURING SANDING OR
GRINDING OPERATIONS, USE NIOSH/MSHA APPRVD MECH FILTER RESPIRATOR
TO REMOVE SOLID AIRBO RNE PARTICLES OF OVERSPRAY (ING 19)
Ventilation:PROVIDE GENERAL DILUTION/LOCAL EXHAUST VENTILATION IN
VOLUME AND PATTERN TO KEEP AIR CONTAM CONC BELOW CURRENT (ING 23)
Other Protective Equipment:DO NOT GET ON SKIN. SOLVENT IMPERMEABLE
CLOTHING AND BOOTS TO PREVENT SKIN CONTACT ARE RECOMMENDED.
Work Hygienic Practices:REMOVE AND WASH SOILED CLOTHING BEFORE REUSE.
WASH HANDS BBEFORE EATING OR SMOKING.
Supplemental Safety and Health
FIRE FIGHT PROC: PREFERABLE. IF EXPOSED TO FIRE/EXTREME HEAT, H*2O
SHOULD BE USED TO COOL CLSD CNTNRS & PVNT PRESS BUILD UP/POSS
AUTO-IGNIT. EXPLO HAZ: DISTANCES & BEYOND CLSD DOORS. DUE TO PRESS
BUIL D-UP, CLSD CNTNRS EXP TO EXTREME HEAT MAY EXPLODE. NEVER USE A
WELDING/CUTTING TORCH ON/NEAR AS PROD/ITS RESIDUE(ING 10)
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:244F,118C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:1.145
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:33.96
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY CAUSE TOXIC FUMES WHEN HEATED TO
DECOMPOSITION. FUMES MAY CONTAIN CARBON MONOXIDE, CARBON DIOXIDE
AND NO*X.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. INCINERATE ONLY IN APPROVED FACILTIY. DO NOT
INCINERATE CLOSED CONTAINERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MOLDENT BUFFING AGENT
CAGE:FO571
CAGE:23048
CAGE:FO571
CAGE:9S392
============= Composition/Information on Ingredients =============
Ingred Name:ABRASIVE
Ingred Name:FATTY ACID
CAS:61788-72-5
RTECS #:LH8024000
Ingred Name:SOAP
Ingred Name:TRIETHANOLAMINE
CAS:102-71-6
RTECS #:KL9275000
Fraction by Wt: 1.5%
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 67-80%
Other REC Limits:0.05 MG/CUM NIOSH
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SKIN: DUST MAY IRRITATE. EYES: DAMAGE
THE OUTER SURFACE. INGESTION: MAY CAUSE GASTROINTESTINAL
DISTURBANCES. INHALATION: RISK OF SERIOUS RESPIRATORY DISEASE
INCREASES.
Explanation of Carcinogenicity:SILICA SHOWS EVIDENCE OF CARCINOGENICITY
TO EXPERIMENTAL ANIMALS/LIMITED EVIDENCE W/RESPECT TO HUMANS.
Effects of Overexposure:SKIN: DUST MAY IRRITATE. EYES: DAMAGE TO THE
OUTER SURFACE. INGESTION: MAY CAUSE GASTROINTESTINAL DISTURBANCES.
INHALATION: RISK OF SERIOUS RESPIRATORY DISEASE INCREASES.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINUTES. SKIN: WASH W/SOAP/WATER.
INGESTION: INDUCE VOMIT. INHALATION: REMOVE TO FRESH AIR. SEEK
MEDICAL ATTENTION AS NEEDED.
===================== Fire Fighting Measures =====================
Flash Point:>350F
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL, CO2, OR SMOTHERING.
THIS ADDITION OF METAL DUST MAY CHANGE RECOMMENDED.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS IF
THERE IS POTENTIAL FOR EXPOSURE TO SMOKE, FUMES OR PRODUCTS OF
COMBUSTION.
Unusual Fire/Explosion Hazard:WATER OR FOAM MAY CAUSE VIOLENT FROTHING,
ESPECIALLY IF SPRAYED DIRECTLY INTO BURNING LIQUID.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE CLOTHING. RECLAIM FOR REUSE IF
POSSIBLE, OR SWEEP, SCOOP UP/CONTAINERIZE FOR LATER DISPOSAL. THIS
PRODUCT ISN'T A HAZARDOUS WASTE BY ITSELF, BUT BE SURE TO CHECK IF
IT HAS COME IN CONT ACT W/HAZ. SUBSTANCE OR MATERIAL
BEFOREDISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF SUN/AWAY FROM HEAT.
PROTECT PASTE OR LIQUID PRODUCTS FROM FREEZING. OBSERVE ALL
SAFEGUARDS FOR CONTAINER RESIDUE UNTIL CLEANED/DESTROYED.
Other Precautions:DURING A BUFFING OPERATION, USE AN EXHAUST, EYE
MATERIAL BEING REMOVED DURING BUFFING FROM ENTERING THE NOSE,
THROAT/SKIN OF THE OPERATOR.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE OSHA APPROVED DUST/MIST RESPIRATOR
Ventilation:AIRBORNE EXPOSURE LIMITS ARE EXCEEDED DURING USE.
Other Protective Equipment:CLEAN WORKCLOTHES, EYE WASH
Work Hygienic Practices:WASH AFTER PHYSICAL CONTACT/BEFORE EATING.
DON'T PERMIT DUST TO ACCUMULATE IN WORK AREA.
Supplemental Safety and Health
OSHA STUDIES HAVE FOUND A BREATHING ZONE CONCENTRATION FOR BUFFING
EQUIPMENT W/NO VENTILATION TO BE APPROX. 1.4 MG/M3 FOR TOTAL RESP.
DUST. AFTER BUFFING CPDS HAVE BEEN USED THERE IS NORMALLY PRODUCED
A WASTE CONTAINING DRIED BUFFING CPD, BUFFING WHEEL LINT OF
COTTON/POLYESTER, ETC; PLUS DUST FROM THE MATERIAL.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>700F
Melt/Freeze Pt:M.P/F.P Text:>125F
Spec Gravity:1.6-1.8
pH:8-9
Solubility in Water:MODERATE
Appearance and Odor:DENSE REDDISH COLORED BRICK WITH MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
POWERFUL OXIDIZERS, FLUORINE, CHLORINE, STRONG BASE OR ALKALI
Stability Condition to Avoid:TEMPERATURES >350F, SUN, HEAT, & FREEZING.
Hazardous Decomposition Products:CARBON, SMOKE, FUMES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE &
FEDERAL REGULATIONS. WASTE GENERATED FROM A BUFFING OPERATION CAN
CONTAIN LINT WHICH MAY BE COMBUSTIBLE. DUST GENERATED DURING
BUFFING MAY CONTAIN SILI CA OR TRIPOLI.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ZINC PERCHLORATE, HYDRATED, REAGENT 102
Preparer's Name:L.M.
CAGE:0TNM0
CAGE:0TNM0
============= Composition/Information on Ingredients =============
Ingred Name:PERCHLORIC ACID, ZINC SALT, HEXAHYDRATE; (ZINC PERCHLORATE,
HYDRATED, REAGENT) (MFR CAS #13637-61-1)
CAS:10025-64-6
RTECS #:SD0525000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CORROSIVE TO SKIN & EYES. TOXICITY IS
LOW.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . SKIN:FLUSH W/COPIOUS
AMOUNTS OF WATER. CALL MD . EYE:WASH WELL W/WATER FOR AT LEAST 1 5
MINUTES, IF IRRITATION PERSISTS AFTERWASHING GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:OXIDIZING MATERIAL (ABOVE 150C). MAY
CAUSE FIRE WHEN HOT & IN CONTACT W/OXIDIZING MATTER.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP & DISCARD TO SINK OR LEACH BED. WASH
AREA WELL W/WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM ORGANIC MATTER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:EMERGENCY EYE WASH & DELUGE SHOWER WHICH
MEET ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EYE PROT:& FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
Spec Gravity:2.25
Solubility in Water:VERY SOLUBLE
Appearance and Odor:WHITE, MOIST CRYSTALS; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE W/REDUCING AGENTS OR ORGANIC MATTER.
Stability Condition to Avoid:OXIDIZING WHEN HOT.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . CHECK LOCAL SEWERAGE REGULATIONS PRIOR TO DISPOSAL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:POTASSIUM IODATE
CAGE:63415
CAGE:60777
CAGE:63415
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM IODATE
CAS:7758-05-6
RTECS #:NN1350000
Fraction by Wt: 100%
===================== Hazards Identification =====================
LD50 LC50 Mixture:IPR MOUSE 136 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE IRRITATING TO EYES,SKIN,MUCOUS
MEMBRANES.
Effects of Overexposure:EYE: IRRITATION. SKIN: MAY BE IRRITATING.
INHALED: IRRITATING TO RESPIRATORY TRACT. INGESTED: NO HUMAN DATA.
PRODUCED EMESIS IN DOGS.
Medical Cond Aggravated by Exposure:NONE LISTED BY MFR.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH WITH WATER. SKIN:WASH WITH SOAP & WATER.
INHALED:REMOVE FROM EXPOSURE. GIVE OXYGEN OR CPR IF NEEDED. GET
MEDICAL ATTENTION. INGESTED:NO SPECIFIC ANTIDOTE. GIVE WATER AND
INDUCE VOMITING. GET IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS. MOVE
CONTAINERS FROM FIRE IF POSSIBLE.
Unusual Fire/Explosion Hazard:OXIDIZER. THERE IS VERY LITTLE HAZARD DUE
TO HEAT OR FLAME IF COMBUSTIBLES ARE ABSENT.
================== Accidental Release Measures ==================
Spill Release Procedures:NO SPECIAL PRECAUTIONS REPORTED BY MFR. HMIS:
AVOID CONTACT WITH INCOMPATABLES DURING CLEAN-UP.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY AREA, AWAY FROM
ORGANICS, COMBUSTIBLES, ETC. (SEE INCOMPATABLES)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH RESPIRATOR FOR DUSTS AND HALOGENS OR
SUPPLIED AIR RESPIRATOR IF EXPOSED ABOVE TLV FOR NUISANCE DUSTS.
Ventilation:USE LOCAL EXHAUST IF NECESSARY TO REDUCE EXPOSURE
Other Protective Equipment:NO SPECIAL CLOTHING. EYE WASH AND SAFETY
SHOWER
Work Hygienic Practices:USE NORMAL CHEMICAL HYGIENE PRACTICES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:D1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:=100.C, 212.F
B.P. Text:WATER BOILS
Melt/Freeze Pt:=560.C, ######F
Decomp Temp:=100.C, 212.F
Decomp Text:LOOSES WATER
Spec Gravity:3.930
Solubility in Water:4.74GM
Appearance and Odor:COLORLESS TO WHITE CRYSTALS OR CRYSTALLINE POWDER,
NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTIVE METALS,CARBON,ORGANICS,REDUCING
AGENTS,SULFUR,COPPER,ARSENIC,PHOSPHORUS
Stability Condition to Avoid:NONE REPORTED BY MFR.
Hazardous Decomposition Products:HYDROGEN IODIDE, POTASSIUM OXIDE
FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W FEDERAL,STATE,LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:POOL-COAT CEMENT
CAGE:2N005
CAGE:2N005
============= Composition/Information on Ingredients =============
Ingred Name:CHLORINATED RUBBER
CAS:9006-03-5
Fraction by Wt: 41%
ACGIH TLV:200 PPM/8 HR
Ingred Name:TITANIUM DIOXIDE, TIO2
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 31%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC, HIGH FLASH
AROMATIC NAPHTHA
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: <47.65%
ACGIH TLV:200 PPM
Ingred Name:ISOPARAFFINIC HYDROCARBONS (NAPHTHA PETROLEUM),
HYDROTREATED HEAVY, NON AROMATIC HEAVY NAPHTHA) ISOPAR G *92/4*
CAS:64742-48-9
Fraction by Wt: <47.65%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: DIZZINESS & HEADACHES.
SKIN: DRYING & IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: UNCONSCIOUSNESS. SKIN: DEFATTING &
DERMATITIS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE IMMEDIATELY IF OVERCOME BY
VAPOR. INGESTION: DON'T INDUCE VOMITING. SKIN: REMOVE CONTAMINATED
CLOTHING AND WASH W/SOAP & WARM WATER. EYES: FLUSH W/CLEAR WATER
FOR 15 M INS OR UNTIL IRRITATION SUBSIDES. OBTAIN MEDICAL ATTENTION
IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:101F
Extinguishing Media:FOAM, DRY CHEMICAL, CO2 FOG OR SPRAY
Fire Fighting Procedures:USE AIR SUPPLIED BREATHING EQUIPMENT FOR
ENCLOSED AREAS.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP PEOPLE AWAY/RECOVER FREE LIQUID & ADD
ABSORBANT (SAND/EARTH/SAWDUST). VENTILATE CONFINED SPACES/OPEN ALL
WINDOWS & DOORS/KEEP PETROLEUM PRODUCTS OUT OF SEWERS & WATER
SOURCES BY DIKING OR IMPOUND ING. REMOVE ALL IGNITION SOURCES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE CLOSED/DON'T HANDLE OR STORE
NEAR SPARKS/FLAME/STRONG OXIDANTS OR CONCENTRATED OXYGEN/ADEQUATE
VENTILATION EQUAL TO OUTDOORS IS REQUIRED.
Other Precautions:AVOID BREATHING VAPORS & PROLONGED OR REPEATED
CONTACT WITH SKIN/STORE IN BUILDINGS DESIGNED TO HOLD NFPA CLASS
II FLAMMABLE LIQUIDS/NO SMOKING OR OPEN LIGHTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:HYDROCARBON VAPOR CANISTER OR SUPPLIED-AIR
RESPIRATORY PROTECTION IN CONFINED OR ENCLOSED SPACES IF NEEDED.
Ventilation:LOCAL EXHAUST FACE VELOCITY: 60 FPM. SPECIAL: USE ONLY W/
ADEQUATE VENTILATION. MECHANICAL: EXPLOSION-PROOF EQUIPMENT.
Other Protective Equipment:CHEMICAL RESISTANT APRON OR OTHER CLOTHING
TO AVOID REPEATED OR PROLONGED SKIN CONTACT.
Work Hygienic Practices:REMOVE CONTAMINATED SHOES & THOROUGHLY DRY
BEFORE REUSE. REMOVE AND LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:300F
Vapor Pres:30
Vapor Density:5.0
Solubility in Water:INSOLUBLE
Appearance and Odor:WATER WHITE, STRONG AROMATIC ODOR
Percent Volatiles by Volume:95
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDENTS LIKE LIQUID CHLORINE, SODIUM OR CALCIUM HYPOCHLORITE,
AND CONCENTRATED OXYGEN.
Stability Condition to Avoid:IGNITION SOURCES SUCH AS HEAT, SPARKS OR
FLAME.
Hazardous Decomposition Products:CO AND CO2 FUMES, SMOKE AND CARBON
MONOXIDE, IN THE CASE OF INCOMPLETE COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE WITH ALL APPLICABLE DISPOSAL
REGULATIONS. DISPOSE OF ABSORBED MATERIAL AT AN APPROVED DISPOSAL
SITE OR FACILITY. ADVISE AUTHORITIES IF IT ENTERS SEWERS, WATER OR
EXTENSIVE LAND AREAS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:5R318 5047 CLASS IV DEVELOPER
CAGE:26921
CAGE:26921
============= Composition/Information on Ingredients =============
Ingred Name:IRON *98-3*
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: >94%
Ingred Name:1,3-BUTADIENE POLYMER, STYRENE-BUTADIENE POLYMER, SBS, SBS
(BLOCK POLYMER)
CAS:9003-55-8
RTECS #:WL6478000
Fraction by Wt: <3.75-4%
Ingred Name:RED IRON OXIDE/IRON (III) OXIDE/FERRIC OXIDE/YELLOW FERRIC
OXIDE/YELLOW IRON OXIDE/IRON OXIDE PIGMENT
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: <0.75-1%
OSHA PEL:10 MG/CUM
ACGIH TLV:5 MG/CUM (FE)
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RATS): >10 G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MINIMAL RESPIRATORY TRACT IRRITATION
MAY OCCUR AS W/EXPOSURE TO LARGE AMOUNTS OF ANY NON-TOXIC DUST.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:MINIMAL RESPIRATORY TRACT IRRITATION MAY OCCUR
AS W/EXPOSURE TO LARGE AMOUNTS OF ANY NON-TOXIC DUST.
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE. EYES: FLUSH W/WATER. SKIN:
WASH W/SOAP & WATER. INGESTION: DILUTE STOMACH CONTENTS W/SEVERAL
GLASSES OF WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, FOAM, DRY CHEMICAL
Fire Fighting Procedures:AVOID INHALATION OF SMOKE. WEAR PROTECTIVE
CLOTHING W/SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP/VACUUM.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:AVOID PROLONGED INHALATION OF EXCESSIVE DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN XEROX
EQUIPMENT.
Ventilation:NONE REQUIRED WHEN USED AS INTENDED IN XEROX EQUIPMENT.
Other Protective Equipment:FOR USE AS IN BULK TONER PROCESSING
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:5
Appearance and Odor:BLACK GRANULAR W/FAINT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION MAY BE TOXIC.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:EPLFND,TONER CARTRIDGES,REMANUFACTURED
CAGE:JO161
CAGE:0NU41
CAGE:JO161
============= Composition/Information on Ingredients =============
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: <10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9596
Ingred Name:IRON OXIDE
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 25.45%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5MG(FE)/M3FUME,B2;96
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:PER
MSDS:CARCINOGENICITY:NTP/IARC/OSHA:NO.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE WHEN USED AS INTENDED IN THE
PRONTING EQUIPMENT FOR WHICH IT IS DESIGNED.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOSURE.SKIN:WASH
W/SOAP/WATER.INGEST:DRINK SEVERAL GLASSES OF WATER.
===================== Fire Fighting Measures =====================
Flash Point:NA
Autoignition Temp:Autoignition Temp Text:NA
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:FOAM, DRY CHEMICAL, CO2, WATERSPRAY OR MIST.
Fire Fighting Procedures:AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:MATERIAL IS COMBUSTIBLE.WHEN DISPENSED IN
AIR AS A DUST IT CAN FORM EXPLOSIVE MIXTURES.
================== Accidental Release Measures ==================
Spill Release Procedures:LOOSE INK CAN BE REMOVED USING VACUUM CLEANER
& MAY BE SWEPT UP(AVOID DUST INHAL-USE APPROPRIATE DUST MASK IF
NECESSARY).
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL DRY WELL VENTILATED
AREA.AVOID PROLONGED INHAL OF EXCESSIVE DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED.
Ventilation:NORMALLY NONE REQUIRED.
Other Protective Equipment:NONE REQUIRED WHEN USED AS INTENDED.
Work Hygienic Practices:NORMAL CARE IN HANDLING A PARTICULATE MATERIAL.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NA
Melt/Freeze Pt:M.P/F.P Text:>212F,>100C
Decomp Temp:Decomp Text:NP
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:1.5-1.7
pH:NP
Viscosity:NP
Evaporation Rate & Reference:NA
Solubility in Water:NEGLIGIBLE.
Appearance and Odor:FINE BLACK POWDER,MILD, RESINOUS ODOR.
Percent Volatiles by Volume:NP
Corrosion Rate:NP
================= Stability and Reactivity Data =================
STRONG OXIDANTS.
Stability Condition to Avoid:NA.HMIS:AVOID GENERATING/ACCUMULATING
DUST.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION CAN BE TOXIC
DEPENDING ON CONDITION.AVOID BREATHING.
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL OR INCINERATE.ENSURE CONFORMITY
W/LOCAL, STATE AND FEDERAL REGULATIONS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:ENAMEL,HEAT RESISTANT,BLACK, TT-E-496BTYPE1
CAGE:33151
CAGE:33151
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENTS
Fraction by Wt: 50%
ACGIH TLV:200 PPM
===================== Hazards Identification =====================
Effects of Overexposure:SKIN,EYE
IRRITANT,ANESTHESIA,HEADACHE,DIZZINESS,NAUSEA
======================= First Aid Measures =======================
First Aid:SKIN CONTACT-WASH WITH SOAP AND WATER.EYE CONTACT-FLUSH WITH
PLENTY OF WATER.INHALATION-REMOVE TO FRESH AIR AND RESTORE
BREATHING IF REQUIRED
===================== Fire Fighting Measures =====================
Flash Point:111F,44C TCC
Lower Limits:1.0
Upper Limits:6.0
Extinguishing Media:FOAM,CO*2,STEAM,WATER FOG,DRY CHEMICAL
Fire Fighting Procedures:EXCLUDE AIR,DO NOT USE WATER,CONSULT FIRE
MARSHALL
Unusual Fire/Explosion Hazard:VAPOR FORMS EXPLOSIVE MIXTURE WITH AIR
BETWEE VAPOR AND LOWER EXPLOSION LIMITS
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES,VENTILATE AREA.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID IGNITION SOURCES.AVOID SPLASH
FILLING.PROVIDE ADEQUATE VENTILATION.AVOID EXCESSIVE HEAT
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ORGANIC CANNISTER MASK OR AIR PACK
Ventilation:MECHANICAL WITH APPROVED CLASSD EXPLOSION PROOF
MOTOR/SWITCH
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:323F,162C
Vapor Pres:1
Vapor Density:5.0
Spec Gravity:0.77
Evaporation Rate & Reference:< BUTYL ACETATE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT COLORED LIQUID,HYDROCARBON ODOR.
Percent Volatiles by Volume:56
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO,CO*2 WHEN COMBUSTED
==================== Disposal Considerations ====================
Waste Disposal Methods:EVAPORATION OR FLUSH WITH WATER IN WELL
VENTILATED AREA.USE OIL SEWER IF AVAILABLE OR REMOVE TO CONTAINER
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:57317 W A R M
CAGE:67018
CAGE:67018
============= Composition/Information on Ingredients =============
Ingred Name:DITHIOTHREITOL *98-1*
CAS:27565-41-9
RTECS #:XO8576500
Fraction by Wt: >50%
Ingred Name:PAPAIN
CAS:9001-73-4
RTECS #:RU4950000
Fraction by Wt: >3%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): >10 CM/KG PAPAIN
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: MAY CAUSE IRRITATION.
INHALATION: IRRITATION TO UPPER RESPIRATORY SYSTEM.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH THOROUGHLY W/WATER FOR 15 MINS. SKIN: RINSE
W/PLENTY OF WATER FOR 15 MINS. INHALATION: REMOVE TO FRESH AIR.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:USE EXTINGUISHING MATERIALS APPROPRIATE FOR
SURROUNDING FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: WEAR SUITABLE PROTECTIVE CLOTHING TO
GUARD AGAINST EYES & SKIN. CAREFULLY SWEEP UP MATERIAL TO AVOID
RAISING DUST.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BETWEEN 35.6-46.4F.
RECONSTITUTED PRODUCT SHOULD BE USED W/IN 5 DAYS.
Other Precautions:AVOID CONTACT W/SKIN & EYES. DON'T BREATHE DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED, UNDER NORMAL PRODUCT USE.
Other Protective Equipment:PROTECTIVE CLOTHING
Work Hygienic Practices:GOOD HYGIENE PRACTICES SHOULD BE FOLLOWED TO
AVOID SKIN & EYE CONTACT W/THIS PRODUCT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:COMPLETE
Appearance and Odor:LYOPHILIZED POWDER CAKE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: TRANSBOND PRIMER
Cage: 0K0U5
=======================================================
Contractor Summary
=======================================================
Cage: 0K0U5
=======================================================
Ingredients
=======================================================
Cas: 109-16-0
RTECS #: OZ4100000
% low Wt: 45.
% high Wt: 55.
------------------------------
Cas: 1565-94-2
RTECS #: UD3438000
% low Wt: 44.
% high Wt: 54.
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Effects of Exposure: EYES: MILD IRRITANT. SKIN: ALLERGIC REACTION, MILD
IRRITATION. INHALATION: IRRITATION OF UPPER RESPIRATORY.
Signs And Symptions Of Overexposure: IRRITATION, REDNESS, SWELLING, PAIN,
TEARING, BLISTERING, ITCHING, DRYNESS OF SKIN, SORENESS OF THE NOSE &
THROAT, COUGHING, SNEEZING.
First Aid: EYES/SKIN: IMMEDIATELY FLUSH W/LARGE AMOUNTS OF WATER. INGESTION:
DON'T INDUCE VOMITING. DRINK TWO GLASSES OF WATER. OBTAIN MEDICAL ATTENTION
IN ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: CONTAIN, COLLECT MATERIAL. CLEAN UP RESIDUE.
Waste Disposal Methods: DISPOSE OF WASTE PRODUCT IN A SANITARY LANDFILL.
DISPOSE OF COMPLETELY CURED/POLYMERIZED MATERIAL IN A SANITARY LANDFILL.
DISPOSE OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
Handling And Storage Precautions: STORE OUT OF DIRECT SUNLIGHT.
Other Precautions: AVOID EYE CONTACT. AVOID PROLONGED/REPEATED SKIN CONTACT.
DON'T INGEST.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: WATER SPRAY, CO2, DRY CHEMICAL, FOAM
=======================================================
Control Measures
=======================================================
=======================================================
Physical/Chemical Properties
=======================================================
M.P/F.P Text: 257-437F
Spec Gravity: 0.09
Solubility in Water: INSOLUBLE
Appearance and Odor: SLIGHT ACRYLATE ODOR, LIGHT YELLOW COLOR
Percent Volatiles by Volume: 0
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: STORAGE IN DIRECT SUNLIGHT.
Hazardous Decomposition Products: CO, CO2
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
Federal Regulatory Information: SINCE REGULATIONS VARY, CONSULT APPLICABLE
REGULATIONS/AUTHORITIES BEFORE DISPOSAL. IN THE EVENT OF AN UNCONTROLLED
RELEASE OF THIS MATERIAL, THE USER SHOULD DETERMINE IF THE RELEASE QUALIFIES
AS A RE PORTABLE QUANTITY.
=======================================================
Other Information
=======================================================
Other Information: THE INFORMATION ON THIS DATA SHEET REPRESENTS OUR CURRENT
DATA & BEST OPINION AS TO THE PROPER USE IN HANDLING OF THIS MATERIAL
UNDER NORMAL CONDITIONS. ANY USE OF THE MATERIAL WHICH IS NOT IN CONFORM ANCE
W/THIS DATA SHEET/WHICH INVOLVES USING THE MATERIAL IN COMBINATION W/ANY
OTHER MATERIAL/ANY OTHER PROCESS IS THE RESPONSIBILITY OF THE USER.
=======================================================
HAZCOM Label
=======================================================
Product ID: TRANSBOND PRIMER
Cage: 0K0U5
Company Name: MINNESOTA MINING AND MFG CO DENTAL PRODUCTS DIV
Street: 3M CENTER
Zipcode: 55144-1000
Label Required IND: Y
Date Of Label Review: 06/29/1999
Status Code: A
Origination Code: G
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MS-260 SAFEZONE CLEANER FOR PLASTIC, GLASS & METAL
Preparer's Name:JOANNA SAFFO
CAGE:08598
CAGE:08598
============= Composition/Information on Ingredients =============
Ingred Name:2 BUTOXY ETHANOL
CAS:111-76-2
RTECS #:KJ8575000
= Wt:3.9
OSHA PEL:240 MG/M3;50 PPM
ACGIH TLV:121 MG/M3;25 PPM
Ingred Name:ETHYL ALCOHOL
CAS:64-17-5
RTECS #:KQ6300000
Minumum % Wt:10.
Maxumum % Wt:20.
OSHA PEL:1900 MG/M3;1000 PPM
ACGIH TLV:1880 MG/M3;1000 PPM
Ingred Name:METHYL ALCOHOL
CAS:67-56-1
RTECS #:PC1400000
= Wt:.8
OSHA PEL:260 MG/M3;200 PPM
ACGIH TLV:262 MG/M3;200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:HYDROCARBON PROPELLANT
CAS:68476-85-7
RTECS #:SE7545000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:1800 MG/M3;1000 PPM
ACGIH TLV:1800 MG/M3;1000 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC HEALTH HAZARDS: THIS
PRODUCT CONTAINS 2-BUTOXYETHANOL, WHICH HAS CAUSED LIVER AND KIDNEY
DAMAGE AND HEMOLYTIC ANEMIA IN TEST ANIMALS. SIGNS & SYMPTOMS OF
EXPOSURE: RESPIRATORY IRRITATION . HIGH CONCENTRATIONS MAY PRODUCE
HEADACHE, DIZZINESS AND NAUSEA. PROLONGED OR REPEATED SKIN CONTACT
MAY LEAD TO DRYING, IRRITATION, AND DERMATITIS. POSSIBLE SKIN
ABSORPTION. EYE CONTACT MAY CAUSE BUR NING AND IRRITATION.
Explanation of Carcinogenicity:NONE OF THE INGREDIENTS ARE LISTED AS A
CARCINOGEN BY IARC, NTP, OR OSHA.
Effects of Overexposure:REFER TO HEALTH HAZARDS ACUTE AND CHRONIC.
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE VICTIM TO FRESH AIR AND RESTORE BREATHING IF
NECESSARY. STAY WITH VICTIM UNTIL ARRIVAL OF EMERGENCY MEDICAL
PERSONNEL. EYE: IMMEDIATELY FLUSH EYES WITH LARGE AMOUNTS OF WATER
FOR AT L EAST 15 MINUTES, WHILE HOLDING EYELIDS OPEN. GET PROMPT
MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING AND WASH SKIN
WITH PLENTY OF WATER. IF IRRITATION PERSISTS, SEEK MEDICAL
ATTENTION. INGEST ION: CONTACT LOCAL POISON CONTROL OR PHYSICIAN
IMMEDIATELY!!! NOTE TO PHYSICIAN: N.A.
===================== Fire Fighting Measures =====================
Flash Point:N/D (SUP DATA)
Autoignition Temp:Autoignition Temp Text:N/D
Lower Limits:1.8
Upper Limits:9.2
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SELF-CONTAINED BREATHING
APPARATUS (SCBA) AND FULL PROTECTIVE EQUIPMENT . CONTAINERS SHOULD
BE COOLED WITH WATER TO PREVENT VAPOR PRESSURE BUILD-UP. USE
EQUIPMENT OR SHIELDING , AS REQUIRED, TO PROTECT PERSONNEL FROM
BURSTING, RUPTURING OR VENTING CANS.
Unusual Fire/Explosion Hazard:DO NOT SPRAY NEAR OPEN FLAMES OR WHILE
SMOKING. AT ELEVATED TEMPERATURES OVER 54C/130F CONTAINERS MAY
VENT, RUPTURE OR BURST. FLASH POINT NOT DETERMINED, PROPELLANT
FLASHES BELOW 0 DEGREES FAHRENHEI T. AUTODECOMPOSITION TEMPERATURE:
NOT DETERMINED. PRODUCT IS A FOAM WHICH MAY SUPPORT COMBUSTION WHEN
FRESH.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION AND VENTILATE
AREA. SOAK UP SPILL WITH AN INERT ABSORBENT AND PLACE INTO A
DESIGNATED DISPOSAL CONTAINER. CONSULT LOCAL REGULATORY AGENCY FOR
PROPER DISPOSITION OF MATER IAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE CONDITIONS: DO NOT STORE NEAR
SOURCES OF HEAT, IN DIRECT SUNLIGHT, OR WHERE TEMPERATURES EXCEED
49C/120F. DO NOT PUNCTURE OR DAMAGE CONTAINERS. ROTATE STOCK TO
SHELF LIFE OF ONE YEAR.
Other Precautions:DO NOT SPRAY LIQUID ON HANDS OR DIRECT SPRAY INTO
EYES. PRODUCT IS A FOAM WHICH MAY SUPPORT COMBUSTION WHEN FRESH. DO
NOT SPRAY NEAR OR ON SOURCES OF IGNITION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO RESPIRATORY PROTECTION IS REQUIRED IF GOOD
VENTILATION IS MAINTAINED. USE A NIOSH APPROVED RESPIRATOR TO
PREVENT OVEREXPOSURE.
Ventilation:LOCAL EXHAUST IS ADEQUATE UNDER NORMAL CONDITIONS. IF
SPRAYING LARGE AMOUNTS, ADEQUATE VENTILATION SHOULD BE USED.
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA .
Supplemental Safety and Health
FIRE AND EXPLOSION HAZARD: PROPELLANT FLASHES BELOW 0 DEGREES F.
PHYSICAL/CHEMICAL PROPERTIES: DENSITY: 0.95 GM/CC @ 77F.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:N.A.
Vapor Pres:140 PSIG @ 130F.
Vapor Density:>1 (AIR=1)
pH:8.5
Evaporation Rate & Reference:<1.0 (CCL4=1).
Solubility in Water:COMPLETE.
Appearance and Odor:WHITE FOAM, WIDE HOLLOW CONE SPRAY, FLORAL
FRAGRANCE. SEMI-STABLE FORM.
Percent Volatiles by Volume:100%.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, HEAT AND OPEN FLAMES.
Stability Condition to Avoid:AVOID SPRAYING NEAR OPEN FLAMES OR RED HOT
COILS.
Hazardous Decomposition Products:COMBUSTION MAY PRODUCE CARBON MONOXIDE
AND CARBON DIOXIDE, ADDITIONAL TOXIC CHEMICALS MAY BE FORMED IN
SMALL AMOUNTS.
=================== Toxicological Information===================
Toxicological Information:EXPOSURE LIMITS FOR PRODUCT (MS-260) CANNOT
BE DETERMINED.
===================== Ecological Information =====================
Ecological:AQUATIC TOXICITY: N.A.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT PUNCTURE OR INCINERATE CONTAINERS. WHEN
CONTENTS ARE DEPLETED CONTINUE TO DEPRESS BUTTON UNTIL ALL GAS IS
EXPELLED. DISPOSE OF CONTAINER IN ACCORDANCE WITH FEDERAL, STATE
AND LOCAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:DOMESTIC (DOT) PROPER SHIPPING NAME: CONSUMER
COMMODITY ORM-D. INTERNATIONAL AIR (IATA) PROPER SHIPPING NAME:
AEROSOL, FLAMMABLE. HAZARD CLASS: 2.1. UN #: 1950. DOT/IATA LABEL:
FLAMMABLE GAS.
===================== Regulatory Information =====================
SARA Title III Information:PRODUCT HAZARD CATAGORIES: CHRONIC HEALTH -
NO. ACUTE HEALTH - YES. FIRE HAZARD - YES. PRESSURE HAZARD - NO.
REACTIVITY HAZARD - NO. LISTS: EXTREMELY HAZARDOUS SUBSTANCE - NO.
CERCLA HAZARDOUS SUBSTAN CE - YES (2-BUTOXY ETHANOL AND METHYL
ALCOHOL COMPONENTS ONLY). TOXIC CHEMICALS - YES (2-BUTOXY ETHANOL
AND METHYL ALCOHOL COMPONENTS ONLY).SARA TITLE III STATUS:
REPORTED. INCLUDED.
Federal Regulatory Information:TSCA INVENTORY STATUS: REPORTED.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ASBESTOS FILLED SPIRAL WOUND GASKET
CAGE:72433
CAGE:4A760
CAGE:72433
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9293
Ingred Name:NATURAL LATEX
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:PRODUCT IS NOT A HEALTH HAZARD UNDER
ORDINARY CONDITIONS OF USE. DUST FROM ABRASIVE ACTIONS (CUTTING,
MACHINING, FILING, DRILLING, ETC.) MAY CONTAIN ASBESTOS FIBERS.
CHRONIC OVEREXPOSURE TO AIRBORNE F IBERS MAY LEAD TO
ASBESTOSIS,LUNG CANCER, MESOTHELIOMA.SMOKING WITH FIBER INHALATION
GREATLY INCREASES LUNG CANCER RISK.
Explanation of Carcinogenicity:THIS PRODUCT CONTAINS ASBESTOS AND IS
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:EYES: IRRITATION FROM AIRBORNE DUST. SKIN:
MECHANICAL IRRITATION FROM DUST. INHALATION: INHALATION OF AIRBORNE
DUST CONTAINING ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR
LEAD TO ASBESTOSIS, LUN G CANCER, MESOTHELIOMA. INGESTION:
FREEASBESTOS FIBERS MAY BE A FACTOR IN CANCER OF THE GI TRACT AND
LARNYX.
Medical Cond Aggravated by Exposure:PERSON WITH PRE-EXISTING DISEASE
INVOLVING THE EYES, SKIN, OR RESPIRATORY TRACT MAY BE AT INCREASED
RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. GET MEDICAL
ATTENTION. SKIN: WASH AREA WITH SOAP AND WATER. IF IRRITATION
PERSISTS GET MEDICAL ATTENTION. INHALATION: MOVE TO FRESH AIR. GET
MEDICAL ATTENTION.INGESTION: INDUCE VOMITING. GET MEDICAL
ATTENTION. OTHER: CHANGE CLOTHING AS REQUIRED TO AVOID CARRYING
DUST PARTICLES INTO OTHER AREAS.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE. WATER,
FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:IF FIRE INVOLVES LARGE AMOUNTS OF PRODUCT,
WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT DUE TO
SMOKE AND POSSIBLE RELEASE OF ASBESTOS FIBERS.
Unusual Fire/Explosion Hazard:PRODUCES SMOKE, SOME FUMES AND POSSIBLY
SOME FREE ASBESTOS FIBERS WHEN BURNED.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED
WITH AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS
FIBERS TO THE ATMOSPHERE. D O NOT DRY SWEEP OR USE COMPRESSED AIR.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLEAN DRY PLACE AWAY FROM
INCOMPATIBLE MATERIAL. HANDLE IN A MANNER TO MINIMIZE FORMATION OR
RETENTION OF AIRBORNE DUST.
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS AND
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED AND BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL CONDITIONS OF USE. IF
ANY OPERATIONS ARE PERFORMED ON THE PRODUCT THAT MAY RELEASE
ASBESTOS FIBERS, USE A NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS.
Ventilation:NONE REQUIRED UNDER NORMAL CONDITIONS OF USE. LOCAL EXHAUST
IS RECOMMENDED IN SITUATIONS WHERE DUST IS GENERATED.
Other Protective Equipment:NONE NORMALLY REQUIRED.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. AVOID AIRBORNE DUST GENERATION.
Supplemental Safety and Health
CHANGE CLOTHING AS REQUIRED TO AVOID CARRYING DUST PARTICLES INTO OTHER
AREAS. SMOKING ALONG WITH ASBESTOS FIBER INHALATION GREATLY
INCREASES CANCER RISK.
================== Physical/Chemical Properties ==================
HCC:T6
Spec Gravity:2.5
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT BLUE. NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
DIRECT FLAME WILL IGNITE BINDER.
Stability Condition to Avoid:STABLE UNDER NORMAL CONDITIONS OF STORAGE
AND USE.
Hazardous Decomposition Products:IN A FIRE, SMOKE, CARBON MONOXIDE
RELEASED UNDER CERTAIN CONDITIONS. ASBESTOS FIBERS MAY BE RELEASED
ONCE BINDER BURNED.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS. DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED F OR ASBESTOS DISPOSAL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PAM X WHITE, 7071
Preparer's Name:L ANDERSON
CAGE:FO323
CAGE:1G327
CAGE:FO323
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: DIRECT CONTACT MAY CAUSE SLIGHT
IRRITATION. SKIN: PROLONGED & REPEATED SKIN CONTACT MAY RESULT IN
REDNESS AND IRRITATION. INHAL: NO SYMPTOMS SEEN WHEN THIS PRODUCT
IS USED IN ITS INTENDED MANNER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE: GENTLY FLUSH W/LGE QTYS OF WATER FOR AT LEAST 15 MINS &
SEEK MED ATTN IF IRRIT PERSISTS. SKIN: WASH AFFECTED SKIN AREAS
W/SOAP & WATER & SEEK MEDICAL ATTN IF IRRITATION PERSISTS. INHAL:
REMOVE TO FRESH AIR. SUPPORT BREATHING(GIVE O*2/ARTF RESP).
INGEST: INDUCE VOMITING AND SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>200F,>93C
Extinguishing Media:USE FOAM, CO*2 OR DRY CHEMICAL FIRE APPARATUS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT. USE WATER SPRAY TO COOL NEARBY CONTAINERS AND
STRUCTURES EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP &/CONTAIN DISCHARGE IF IT MAY BE DONE
SAFELY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP PRODUCT CONTAINERS CLOSED WHEN
NOT IN USE.
Other Precautions:EMPTIED CNTNRS MAY RETAIN PRODUCT RESIDUES;
THEREFORE, ALL HAZARD PRECAUTIONS GIVEN IN THIS DATA SHEET SHOULD
BE OBSERVED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NECESSARY. USE NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:0.96
pH:6.5
Solubility in Water:100%
Appearance and Odor:THICK, OPAQUE WHITE LIQUID W/MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:THERMAL DECOMPOSITION IN THE PRESENCE
OF AIR MAY YIELD CARBON MONOXIDE AND/CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, COUNTY, STATE
& FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:215-11, REGAL WALL SATIN GOLDEN GLOW
CAGE:09585
CAGE:09585
CAGE:91950
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA III). VP: 0.1 @ 77F.
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 2.1-2.2%
OSHA PEL:50 PPM, C
ACGIH TLV:50 PPM, VAPOR, C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 1.6-2.9%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:STODDARD SOLVENT; (ODORLESS MINERAL SPIRITS). VP: 1.2 @
20C.
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 1.4-1.5%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF RESPIRATORY
TRACT. SKIN/EYE: PRIMARY IRRITATION. INGESTION OF LARGE AMOUNTS
COULD CAUSE SERIOUS INJURY. POSSIBLE ANESTHETIC EFFECT FFROM
MINERAL SPIRITS CONTENT.
Explanation of Carcinogenicity:CRYSTALLINE SILICA (QUARTZ): GROUP 2
(NTP), 2A (IARC).
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE EXPECTED WHEN USED IN
ACCORDANCE WITH SAFE HANDLING AND USE INFORMATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GET MEDICAL HELP FOR ANY
BREATHING DIFFICULTY. EYE: FLUSH THOROUGHLY WITH WATER FOR AT LEAST
15 MINUTES. CALL PHYSICIAN. SKIN: WASH WITH SOAP AND WATER.
INGESTION: DRI NK 1 OR 2 GLASSES OF WATER TO DILUTE. DO NOT INDUCE
VOMITING. CALL PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>250F,>121C
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . COOL EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY BURST IF EXPOSED TO
EXTREME HEAT OR FIRE. TOXIC GASES MAY FORM WHEN PRODUCT BURNS.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH WITH WATER. ABSORB WITH SAWDUST OR RAGS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT THROW OR DROP CONTAINERS.
Other Precautions:AVOID CONTACT WITH EYES AND PROLONGED CONTACT WITH
SKIN OR BREATHING OF SPRAY MIST OR SANDING DUST. CLOSE CONTAINER
AFTER EACH USE. KEEP OUT OF REACH OF CHILDREN. DO NOT TAKE
INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR SPECIFIED FOR
PROTECTION AGAINST PAINT SPRAY, DUST AND SANDING DUST IN RESTRICTED
OR CONFINED AREAS.
Ventilation:ADEQUATE TO MAINTAIN WORKING ATMOSPHERE BELOW TLV AND LEL.
MECHANICAL EXHAUST MAY BE REQUIRED IN CONFINED AREAS.
Other Protective Equipment:CLOTHING ADEQUATE TO PROTECT SKIN.
Work Hygienic Practices:REMOVE AND WASH CLOTHING BEFORE REUSE. WASH
HANDS BEFORE EATING, SMOKING OR USING WASHROOM.
Supplemental Safety and Health
% VOLAT: 61.5-67.5.
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Pres:ING 1, 2
Vapor Density:HVR/AIR
Spec Gravity:1.28-1.33
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:ELEVATED TEMPERATURES.
Hazardous Decomposition Products:BURNING MAY PRODUCE CO2 AND CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONVENTIONAL PROCEDURES IN COMPLIANCE WITH
LOCAL, STATE AND FEDERAL REGULATIONS. DO NOT INCINERATE SEALED
CONTAINERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:RAPID SET NON-SHRINK MULTIPURPOSE GROUT (SU
CAGE:CTSCE
CAGE:CTSCE
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE - FUSED
CAS:60676-86-0
RTECS #:VV7328000
Fraction by Wt: 15.4%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:ALUMINUM OXIDE
CAS:1344-28-1
RTECS #:BD1200000
Fraction by Wt: 13.74%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:IRON (III) OXIDE
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 2.38%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
Ingred Name:CALCIUM OXIDE
CAS:1305-78-8
RTECS #:EW3100000
Fraction by Wt: 50.87%
OSHA PEL:5 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:MAGNESIUM OXIDE
CAS:1309-48-4
RTECS #:OM3850000
Fraction by Wt: 1.26%
OSHA PEL:15 MG/M3 PARTICULATE
ACGIH TLV:10 MG/M3;TDUST; 9293
Ingred Name:SULFUR TRIOXIDE
CAS:7446-11-9
RTECS #:WT4830000
Fraction by Wt: 12.52%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:(ACUTE) DRY CEMENT, WHEN COMBINED WITH
BODY MOISTURE AND WET CEMENT, ESPECIALLY AS AN INGREDIENT IN
PLASTIC (UNHARDENED) CONCRETE, CAN DRY SKIN AND CAUSE ALKALI BURNS.
CEMENT DUST CAN IRRITATE EYES AN D UPPER RESPIRATORY SYSTEM.
(CHRONIC) CEMENT DUST CAN CAUSE INFLAMMATION OF LINING TISSUE OF
INTERIOR (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: OF NOSE AND INFLAMMATION OF CORNEA.
HYPERSENSITIVE INDIVIDUALS MAY DEVELOP AN ALLERGIC DERMATITIS.
(CEMENT MAY CONTAIN TRACES OF HEXAVELENT CHROMIUM).
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IRRIGATE EYES WITH WATER FOR AT LEAST 15 MINUTES. SKIN:
WASH AFFECTED AREAS OF BODY WITH SOAP AND WATER. INHALATION: REMOVE
FROM EXPOSURE. SUPPORT BREATHING (GIVE ARTIFICIAL
RESPIRATION/OXYGEN) . INGESTION: CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE CONDITIONS
.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:USE DRY CLEAN-UP METHODS THAT DO NOT DISPERSE
DUST INTO AIR. AVOID BREATHING DUST.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE.
Other Precautions:PRECAUTIONS MUST BE OBSERVED BECAUSE CEMENT BURNS
OCCUR WITH LITTLE WARNING-LITTLE HEAT IS SENSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN DUSTY ENVIRONMENTS, USE NIOSH/MSHA APPROVED
RESPIRATOR.
Ventilation:LOCAL EXHAUST CAN BE USED, IF NECESSARY, TO CONTROL
AIRBORNE DUST LEVELS.
Other Protective Equipment:USE BARRIER CREAMS, BOOTS & CLTHG TO PROT
SKIN FROM PRLNGD CONT W/CEMENT, ESPEC WET CEMENT IN PLASTIC
CONCRETE.
Work Hygienic Practices:IMMEDIATELY AFTER WORKING WITH CEMENT, WORKERS
SHOULD SHOWER WITH SOAP AND WATER.
Supplemental Safety and Health
TRADE NAME/PART #: EXTRA HIGH STRENGTH MIX. SOL IN H2O: (TYPICALLY
0.1-1%).
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:3.10
Solubility in Water:SLIGHT (SUPP DATA)
Appearance and Odor:GRAY (OR WHITE) POWDER, ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:MOISTURE.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:MATERIAL CAN BE RETURNED TO CONTAINER FOR LATER
USE, OR IT CAN BE DISPOSED OF AS COMMON WASTE. DISPOSE IN
ACCORDANCE WITH FEDERAL, STATE, AND LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:EOSIN B, CERTIFIED (C.I. 45400), 86100-6
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:EOSIN B, CERTIFIED
CAS:548-24-3
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE HARMFUL BY INHALATION,
INGESTION, OR SKIN ABSORPTION. MAY CAUSE EYE IRRITATION. MAY CAUSE
SKIN IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT
LEAST 15 MINUTES. SKIN: IMMEDIATELY WASH WITH SOAP AND COPIOUS
AMOUNTS OF WATER. INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING
GIVE ART IFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, GIVE
OXYGEN. INGESTION: WASH OUT MOUTH WITH WATER PROVIDED PERSON IS
CONSCIOUS. CALL PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL POWDER OR
APPROPRIATE FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
WASTE DISPOSAL. AVOID RAISING DUST. VENTILATE AREA AND WASH SPILL
SITE AFTER MATERIAL PICKUP IS COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP TIGHTLY CLOSED. STORE IN A COOL
DRY PLACE.
Other Precautions:AVOID INHALATION. AVOID CONTACT WITH EYES, SKIN AND
CLOTHING. AVOID PROLONGED OR REPEATED EXPOSURE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:BROWN TO DARK-GREEN POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF CARBON MONOXIDE, CARBON
DIOXIDE, NITROGEN OXIDES, HYDROGEN BROMIDE GAS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE OR MIX MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. DISPOSE OF IN ACCORDANCE WITH FEDERAL,
STATE, AND LOCAL REGULATIONS (F P N).
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TRISODIUM PHOSPHATE CRYSTALS
CAGE:85974
CAGE:85974
CAGE:0AZD7
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM PHOSPHATE, TRIBASIC (CERCLA)
CAS:7601-54-9
RTECS #:TC9490000
Fraction by Wt: >95%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE AND SKIN CAUSES IRRITATION.
IHNALATION OF HEAVY DUST MAY IRRITATE NOSE AND THROAT. INGESTION
MAY INJURE MOUTH, THROAT, AND GASTROINTESTINAL TRACT. CHRONIC: NO
LONG TERM HUMAN STUDIES HAVE B EEN REPORTED.
Effects of Overexposure:EYE AND SKIN: CAUSES IRRITATION. NO SIGNIFICANT
SKIN ABSORPTION HAZARD. INHALATION: SMALL AMOUNTS OF DUST ARE VERY
IRRITATING. INGESTION: SLIGHT TOXIC.
Medical Cond Aggravated by Exposure:PRE-EXISTING DISEASE INVOLVING THE
EYES, SKIN, OR RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM
EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. GET MEDICAL ATTENTION.
EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR 15 MINUTES HOLDING
EYELIDS OPEN. GET MEDICAL ATTENTION. SKIN: WASH WITH SOAP AND
WATER. IF IRRITA TION PERSISTS, GET MEDICAL ADVICE. INGESTION:DO
NOT INDUCE VOMITING. RINSE OUT MOUTH TO CAUSE PARTICLES TO
DISSOLVE.GIVE NOTHING BY MOUTH. GET IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NON COMBUSTIBLE
Extinguishing Media:NONE STATED BY THE MANUFACTURER.
Fire Fighting Procedures:NONE STATED BY THE MANUFACTURER.
Unusual Fire/Explosion Hazard:NONE STATED BY THE MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:MATERIAL SHOULD BE SWEPT UP FOR SALVAGE OR
DISPOSAL. EXERCISE CAUTION TO PREVENT GENERATING DUST.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, VENTILATED AREA.
KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. USE APPROVED
RESPIRATORY PROTECTION IF AIRBORNE DUST EXPECTED.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE DUST. AVOID
PROLONGED OR REPEATED CONTACT WITH SKIN. WASH THOROUGHLY AFTER
HANDLING. FOR INDUSTRIAL USE ONLY. MATERIAL IS STRONGLY
BASIC(ALKALINE). AVOID CONTACT WITH EYES AND SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATORY PROTECTION,
IF AIRBORNE DUST IS EXPECTED.
Ventilation:MECHANICAL (GENERAL) ROOM VENTILATION IS NORMALLY ADEQUATE.
LOCAL EXHAUST MAY BE REQUIRED IF AIRBORNE DUST IS EXPECTED.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
THIS MATERIAL HAS PH OF 11.2 AS A 1% SOLUTION.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:1832F,1000C
Solubility in Water:12.7% @ 25C
Appearance and Odor:WHITE, GRANULAR POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NONE STATED BY THE MANUFACTURER
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT YOUR LOCAL ENVIRONMENTAL OFFICER. IF
MATERIAL CAN NOT BE SALVAGED, A METHOD OF DISPOSAL IS IN A LANDFILL
IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:91% IPA POUCHES
CAGE:PLANN
CAGE:PLANN
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPYL ALCOHOL; (ISOPROPANOL)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 91%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM;500 STEL
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:LIQUID WILL DRY SKIN, IRRITATE EYES,
MAY CAUSE HEADACHES, DIZZINESS AND NAUSEA IF EXCESSIVELY INHALED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN:FLUSH WITH WATER, WASH WITH SOAP. EYES:IRRIGATE WITH
WATER FOR AT LEAST 15 MINUTES. CONTACT PHYSICIAN IF NECESSARY.
INHAL:REMOVE TO FRESH AIR AND CONTACT PHYSICIAN. INGEST:DRINK
COPIOUS AMOUNTS O F WATER/MILK AND CONTACT PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:68.0F,20.0C
Lower Limits:2%
Upper Limits:12%
Extinguishing Media:FOAM, CARBON DIOXIDE, WATER, SAND
Fire Fighting Procedures:NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . COOL FIRE EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE SPARKS, FLAMES AND SMOKING. AVOID
SKIN CONTACT, RESIDUE MAY BE SLIPPERY. MAY BE RINSED AWAY W/WATER,
MOPPED/SCRAPED UP OR ABSORBED ONTO MATERIAL AND INCINERATED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:STORE IN COOL, DRY PLACE OUT OF DIRECT SUNLIGHT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NORMAL ROOM VENTILATIONS.
Other Protective Equipment:NONE
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:176F,80C
Vapor Pres:20C-35EST
Vapor Density:2.1 EST
Spec Gravity:0.986 (H*2O=1)
pH:7.0
Evaporation Rate & Reference:GREATER THAN WATER
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR LIQUID WITH PLEASANT ODOR.
Percent Volatiles by Volume:99
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, STRONG BASES, OXIDIZING AGENTS
Stability Condition to Avoid:CONTENTS WILL BURN IF EXPOSED TO HEAT,
SPARKS OR OPEN FLAME.
Hazardous Decomposition Products:IF BURNED, CARBON MONOXIDE, CARBON
DIOXIDE, NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS . RINSE WITH COPIOUS AMOUNTS OF WATER INTO
SEWER.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:258273C94 OR 258273C93
Preparer's Name:HMIS TECHNICIAN
CAGE:89346
CAGE:89346
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE:MINOR EYS/SKIN IRRITATION.
INGESTION- IRRITATION OF GI TRACT. INHALATION-IRRITATION OF
RESPIRATORY TRACT. CHRONIC: ASBESTOSIS, LUNG CANCER, &
MESOTHELIOMA, ALL OF WHICH ARE DISABLING AND FATAL D ISEASES OF THE
LUNG. INHALATION AND INGESTION OF ASBESTOS FIBERS MAY CAUSE CANCER
OF THE BOWEL.
Explanation of Carcinogenicity:ASBESTOS IS A KNOWN HUMAN CARCINOGEN.
Effects of Overexposure:INHALATION: FATIGUE AND SHORTNESS OF BREATH
THAT GETS WORSE WITH TIME AND EVENTUALLY BECOMES DISABLING. EYES:
IRRITATION. SKIN: IRRITATION. INGESTION: MILD STOMACH DISTRESS.
DIARRHEA, VOMITING, AND NA USEA.
Medical Cond Aggravated by Exposure:ASTHMA, EMPHYSEMA, AND TUBERCULOSIS
ARE ALL GENERALLY AGGRAVATED BY EXPOSURE TO ASBESTOS FIBERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SEE DOCTOR. EYES: RINSE
THOROUGHLY WITH WATER FOR 15 MINUTES. SEE DOCTOR. SKIN: WASH
THOROUGHLY WITH SOAP AND WATER. IF IRRITATION PERSISTS, SEE DOCTOR.
INGESTION: DIL UTE WITH WATER. DO NOT INDUCE VOMITING.SEE DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:NOT REQUIRED
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM THE MATERIAL WITH A HEPA FILTERED
VACUUM. THE EQUIPMENT SHALL BE USED & EMPTIED SO AS TO MINIMIZE THE
RE-ENTRY OF ASBESTOS INTO THE WORKPLACE. OTHERWISE, WET THE
MATERIAL WITH WATER & SURFACTAN T AND THEN SHOVEL OR MOP UP
CONTAMINATION.
======================Handling and Storage ======================
Handling and Storage Precautions:LINING IS NONFRIABLE & WILL NOT SHED
FIBERS IN NORMAL USE AND STORAGE. USED LININGS SHALL BE WETTED
BEFORE, DURING & AFTER DISASSEMBLY FROM AN VEHICLE
Other Precautions:IF IT IS NECESSARY TO CUT OR IMPACT THE LINING WHILE
INSTALLING IT, WEAR A RESPIRATOR AND PROTECTIVE CLOTHING. USED
LININGS SHALL BE IDENTIFIED AND DISPOSED OF IN ACCORDANCE WITH ALL
LOCAL, STATE AND FEDERAL REGULATIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED HEPA RESPIRATOR IF
REQUIRED. WEAR SELF-CONTAINED BREATHING APPARATUS IF REQUIRED FOR
HIGH LEVELS OF CONTAMINATES.
Ventilation:LOCAL EXHAUST SUFFICIENT TO ENTRAIN ALL PARTICULATE
EMISSIONS. HEPA FILTER REQUIRED. NO LEAKS ON PRESSURE SIDE OF FAN.
Other Protective Equipment:USE COVERALLS OR DISPOSABLE CLOTHING.
Work Hygienic Practices:WET WORK TO THE DEGREE POSSIBLE. WASH HANDS
AFTER HANDLING LINING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
MSDS GENERATED BY HMIS TECHNICIAN.
================== Physical/Chemical Properties ==================
HCC:T6
Solubility in Water:INSOLUBLE
Appearance and Odor:DRY, MOLDED ASBESTOS-METALLIC COMPOSITION LINING
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG MINERAL ACIDS, AND STRONG ALKALIS
Stability Condition to Avoid:ACCUMULATIONS OF DUST
Hazardous Decomposition Products:ASBESTOS DUST
==================== Disposal Considerations ====================
Waste Disposal Methods:WET THE MATERIAL WITH WATER AND SURFACTANT.
PLACE IN 6 MIL THICK POLYETHYLENE PLASTIC BAG. PLACE THESE BAGS
INTO ANOTHER POLY BAG OR A SAFE PLACE UNTIL IT CAN BE SHIPPED TO AN
APPROVED DISPOSAL SITE. IDENTIFY WITH ASBESTOS CANCER WARNING
LABEL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:GUARDPAK COMPONENT A
Preparer's Name:MICHAEL R SANDNER
CAGE:OC634
CAGE:OC634
============= Composition/Information on Ingredients =============
Ingred Name:METHYLENE BISPHENYL ISOCYANATE (MDI) (SARA III)
CAS:101-68-8
RTECS #:NQ9350000
Fraction by Wt: 38%
Other REC Limits:N/K
OSHA PEL:C, 0.02 PPM
ACGIH TLV:0.005 PPM; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:1,1,2-TRICHLORO-1,2,2-TRIFLUOROETHANE (FREON 113) (SARA
III)
CAS:76-13-1
RTECS #:KJ4000000
Fraction by Wt: 5%
Other REC Limits:N/K
OSHA PEL:1000PPM/1250STEL
ACGIH TLV:1000PPM/1250STEL9192
Ozone Depleting Chemical:1
Ingred Name:TRIPHENYL PHOSPHATE
CAS:115-86-6
RTECS #:TC8400000
Fraction by Wt: 3%
Other REC Limits:N/K
OSHA PEL:3 MG/M3
ACGIH TLV:3 MG/M3; 9192
Ingred Name:HIGHER MOLECULAR WEIGHT OLIGOMERS OF 4,4'-DIPHENYLMETHANE
DIISOCYANATE.
CAS:9016-87-9
RTECS #:TR0350000
Fraction by Wt: 38%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 RAT ORAL >20 G/KG.
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY LEAD TO ALLERGIC SENSITIVITY IN
SOME INDIVIDUALS RESULTING IN ASTHMA-LIKE SYMPTOMS UPON EXPOS BELOW
TLV.SENSITIZED PERSONS SHOULD BE REMOVED FROM ANY FURTHER
EXPOS.PERSONS W/ ASTHMA-TYPE CONDITION S OR OTHER CHRONIC RESP
DISEASE SHOULD BE EXCLUDED FROM WORKING W/ 4,4'-DIPHENYLMETHANE
DIISOCYANATE.CONTACT DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:LIQ CAUSES
IRRIT,TEARING,REDNESS,SWELLING.PERM INJURY UNLIKELY.VAPORS >0.02
PPM CAUSE IRRIT.SKIN:IRRIT & DISCOLORATION.CONTACT DERM DUE TO
SPECIFIC SKIN ALLERGY.INGEST:IRRIT,CORR ACTION IN MOUTH, STOMACH &
DIGESTIVE TRACT.INHAL:IRRIT OF MUC MEMB & RESP
TRACT.COUGHING,HEADACHE,SHORTNESS OF BREATH,CHEST TIGHTNESS.
Medical Cond Aggravated by Exposure:ASTHMA OR OTHER CHRONIC RESPIRATORY
DISEASE.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/ PLENTY OF WATER FOR AT LEAST 15 MIN,WHILE
HOLDING LIDS OPEN.GET MD.SKIN:WASH THOROUGHLY WITH SOAP AND
WATER.LAUNDER CLOTHING BEFORE REUSE.INGEST:DO NOT INDUCE
VOMITING.DRINK WATER TO RED UCE CORROSIVITY.GET MD.TREATMENT IS
SYMPTOMATIC.INHAL:REMOVE TO UNCONTAMINATED AREA.GIVE OXYGEN IF
NECESSARY.ASTHMATIC-LIKE SYMPTOMS MAY OCCUR IMMED OR WITHIN SEVERAL
HOURS.GET MD.TREAT SYMPTOMS.
===================== Fire Fighting Measures =====================
Flash Point:SEE SUPP DATA
Extinguishing Media:CARBON DIOXIDE,CHEMICAL FOAM,DRY CHEMICAL,WATER
SPRAY.
Fire Fighting Procedures:WEAR PRESSURE DEMAND SCBA AND FULL PROTECTIVE
EQUIPMENT .AVOID H*2O CONTAMINATION IN CLOSED CONTAINERS;CO*2
EVOLVED CAN CAUSE PRESSURE BUILDUP.
Unusual Fire/Explosion Hazard:H*2O & HOT ISOCYANATE REACT
VIGOROUSLY.THERMAL DECOMP PROD:OXIDES OF CARBON &
NITROGEN.PHOSGENE.TRACE AMTS:HYDROGEN CYANIDE,HYDROGEN
CHLORIDE,HYDROGEN FLUORIDE.
================== Accidental Release Measures ==================
Spill Release Procedures:COVER W/ LOOSE,ABSORB,NON-BIODEGRADABLE
MATL.POUR DEACTIVATING SOLUTION (90% H*2O,8% CONCENTRATED
AMMONIA,2% DETERGENT) OVER SPILL.ALLOW TO REACT FOR 10 MIN OR
LONGER.COLLECT MATL IN OPEN CONTRS.TREAT W/ DEACTIVATING
SOLUTION.ALLOW TO (SEESUPP)
Neutralizing Agent:90% WATER,8% CONCENTRATED AMMONIA,2% DETERGENT
(DEACTIVATING AGENT).
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BETWEEN 50F,10C & 100F,38C.DO
NOT STORE OPEN DRUMS OUTDOORS.DO NOT RESEAL CONTR UNLESS NO
MOISTURE CONTAM HAS OCCURRED.AVOID INHAL/SKIN CONTACT.
Other Precautions:REACTS WITH MOISTURE TO FORM CARBON DIOXIDE GAS.NO
SMOKING IN AREA OF USE.DO NOT USE IN THE GENERAL VICINITY OF ARC
WELDING,OPEN FLAMES OR HOT SURFACES.HEAT AND/OR UV RADIATION MAY
CAUSE THE FORMATION OF HCL AND/OR PHOSGENE .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF MATL IS HEATED/SPILLED IN CONFINED AREA,RESP
PROT SHOULD BE USED.CARTRIDGE TYPE RESP NOT RECOMMENDED FOR USE W/
ISOCYANATES.USE ONLY FOR SHORT-TERM EMER SITUATIONS WHEN O*2 IS
PLENTIFUL.NIOSH/MSHA APPROVED RESPIRATOR FOR (SEE SUPP)
Ventilation:USE LOCAL EXHAUST IF NECESSARY TO MAINTAIN LEVELS BELOW THE
TLV.
Other Protective Equipment:SFTY SHOWER,EYEWASH STATION & DECONTAM SOLN
READILY AVAIL.SEE "REC FOR THE SAFE USE OF & HNDLG OF INSTAPAK
FOAM-(SUP DA)
Work Hygienic Practices:N/K
Supplemental Safety and Health
FL PT:PROD AS SUPPLIED DOES NOT HAVE A FL PT.MATL W/O
CHLOROFLUOROCARBON & FLAME RETARDANTS HAS A FL PT OF 390F,199C
(PMCC).SPILL PROC:STAND UNCOVERED 24-48 HRS.WASH AREA W/
DEACTIVATING SOLUTION.WEARRESP,EYE & SKIN PROTECTION DURING
CLEANUP.RESP PROT:EXPOSURE OF CONCERN .OTHER PROT EQUIP:IN-PLACE
CHEMICALS."
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:150-625F
Decomp Temp:Decomp Text:N/K
Vapor Pres:334 MMHG
Vapor Density:1 (AIR=1)
Spec Gravity:1.27 (WATER=1)
Evaporation Rate & Reference:N/K
Solubility in Water:REACTS WITH WATER
Appearance and Odor:DARK BROWN,SLIGHTLY AROMATIC LIQUID.
Percent Volatiles by Volume:3.2
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONTACT W/ MOISTURE & OTHER MATERIALS CONTAINING ACTIVE
HYDROGEN.H*2O,AMINES,STRONG BASES,ALCOHOLS,SURFACE ACTIVE MAT.
Stability Condition to Avoid:AVOID TEMPERATURE ABOVE 110F,43C OR BELOW
40F,4C.MOISTURE.
Hazardous Decomposition Products:BY FIRE/EXTREME HEAT:OXIDES OF
CARBON,OXIDES OF NITROGEN,TRACES OF HYDROGEN CYANIDE,HYDROGEN
CHLORIDE,HYDROGEN FLUORIDE.
Conditions to Avoid Polymerization:ACCELERATED AT ELEVATED
TEMPERATURES.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR DISPOSE OF IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .ALSO SEE "RECOMMENDATIONS FOR
THE SAFE USE AND HANDLING OF INSTAPAK FOAM-IN-PLACE CHEMICALS."
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:133 7385 EKTACHROME R-3000 COLOR DEVELOPER, PART B
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 60-65%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM CARBONATE
CAS:584-08-7
RTECS #:TS7750000
Fraction by Wt: 30-35%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM HYDROXIDE (CERCLA)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SODIUM SULFITE
CAS:7757-83-7
RTECS #:WE2150000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIMETHYLAMINE BORANE
CAS:74-94-2
RTECS #:IP9450000
Fraction by Wt: <0.1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:KODAK DID NOT GIVE THIS INFO ON THE MSDS
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYE:CAUSES BURNS. SKIN:CAUSES BURNS.
INHALATION:EXPECRED TO BE LOW HAZARD FOR RECOMMENDED HANDLING.
INGESTION:HARMFUL IF SWALLOWED. MAY CAUSE BURNS OF G/I TRACT.
Explanation of Carcinogenicity:IARC LISTS OCCUPATIONAL EXPOSURE TO
STRONG ACID MISTS; IS NEGATIVE W/REGARD TO:ACGIH
CANCER,CALIF.CANCER & REPRODUCTIVE.
Effects of Overexposure:CAUSES EYE, SKIN BURNS. HARMFUL IF SWALLOWED.
MAY CAUSE BURNSOF G/I TRACT.
Medical Cond Aggravated by Exposure:MFR GAVE NO INFORMATION OF MSDS.
======================= First Aid Measures =======================
First Aid:IF ANY SYMPTOMS OCCUR, GET IMMEDIATE MEDICAL ATTENTION.
INHALATION:IF SYMPTOMATIC MOVE TO FRESH AIR. EYE:FLUSH W/PLENTY OF
WATER FOR 15 MIN. SKIN:FLUSH W/WATER 15 MIN. REMOVE CONTAMINATED
CLOTHING & L AUNDER BEFORE REUSE. INGESTION:DO NOT INDUCE VOMITING!
DRINK 1-2 GLASSES OF WATER. (NOTHING BY MOUTH IF UNCONSCIOUS.)
CALL PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:MAY REQUIRE NEUTRALIZATION IF PH <2.0 OR
>12.5. FLUSH TO SEWER W/LARGE AMOUNTS OF WATER.
Neutralizing Agent:MFR GAVE NO INFORMATION OF MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. KEEP AWAY FROM
INCOMPATIBLE SUBSTANCES.
Other Precautions:AVOID CONTACT W/EYES, SKIN & CLOTHING. USE
W/ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NON SHOULD BE NEEDED.
Ventilation:USE GOOD GENERAL VENTILATION (10 CHANGES/HR.) MATCH
VENTILATION RATES TO CONDITIONS.
Other Protective Equipment:EYE BATH, WASHING FACILITIES, SAFETY SHOWER.
PROTECTIVE CLOTHING APPROPRIATE FOR THE RISK OF EXPOSURE.
Work Hygienic Practices:EK: ? HIMIS: USE GOOD INDUSTRIAL HYGIENE
PRACTICES.MINIMIZE PERSONAL CONTACT. WASH THOROUGHLY AFTER
HANDLING.
Supplemental Safety and Health
KAN 966009; PCD 5853; ECOLOGICAL DATA: OXYGEN DEMAND = NONE.
GERMINATION & PLANT EFFECTS = LOW. WASTE TREATMENT MICROBE EFFECT =
LOW. BIOCONCENTRATION = LOW. ADVERSE EFFECTS AFTER DILUTION &
TREATMENT = NONE.KEY1:C2
================== Physical/Chemical Properties ==================
HCC:C2
NRC/State Lic Num:NONE
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:18 MM
Vapor Density:0.6
Spec Gravity:1.36
pH:>13
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID, COLOR, ODORLESS.
Percent Volatiles by Volume:60-65
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS.
Stability Condition to Avoid:STABLE UNDER NORMAL CONDITIONS OF USE.
Hazardous Decomposition Products:NONE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. MAY REQUIRE NEUTRALIZATION IF PH
<2.0 OR >12.5. FLUSH TO SEWER W/LARGE AMOUNTS OF WATER.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:POTASSIUM CARBONATE, ANHYDROUS, 3012
CAGE:DO803
CAGE:DO803
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM CARBONATE; (POTASSIUM CARBONATE, ANHYDROUS)
CAS:584-08-7
RTECS #:TS7750000
Fraction by Wt: 99-100%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT) 1870 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: IRRITATION OF UPPER
RESPIRATORY TRACT. SKIN CONTACT: SEVERE IRRITATION OR BURNS. EYE
CONTACT: SEVERE IRRITATION OR BURNS. INGESTION: IRRITATION AND
BURNS TO MOUTH AND STOMACH. TARGE T ORGANS: EYES, SKIN, MUCOUS
MEMBRANES.CHRONIC: NONE LISTED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE IDENTIFIED.
======================= First Aid Measures =======================
First Aid:INGEST: CALL PHYS. IF SWALLOWED, DO NOT INDUCE VOMIT. IF
CONSCIOUS, GIVE LG AMTS OF WATER. FOLLOW W/DILUTED VINEGAR, FRUIT
JUICE/WHITES OF EGGS BEATEN W/WATER. INHAL: REMOVE TO FRESH AIR. IF
NOT BRTHG , GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE OXYG. PROMPT
ACTION IS ESSTNL. SKIN: IMMED FLUSH W/PLENTY OF WATER FOR @ LST 15
MINS WHILE REMOVING CONTAMD CLTHG & SHOES. WASH CLTHG BEFORE
RE-USE. (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NOTE: DECOMPOSES AT BOILING POINT.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH APPRVD SCBA & FULL PROT CLTHG. WITH
CLEAN SHOVEL, CAREFULLY PLACE MATERIAL INTO CLEAN, DRY CONTAINER
AND COVER; REMOVE FROM AREA. FLUSH SPILL AREA WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED.
SUITABLE FOR ANY GENERAL CHEMICAL STORAGE AREA. DO NOT STORE NEAR
ACIDS. IRRITANT. AVOID CONT W/EYES, SKIN, CLOTHING.
Other Precautions:AVOID BREATHING DUST. KEEP IN TIGHTLY CLSD CONTAINER.
USE W/ADEQUATE VENTILATION. CAUSES SEVERE IRRITATION. MODERATELY
DESTRUCTIVE TO TISSUE. HARMFUL IF SWALLOWED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCENTRATION IS HIGH, USE AN NIOSH
APPRVD APPROP RESPIRATOR OR DUST MASK.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
FUME OR DUST LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
UNIFORM.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
FIRST AID PROC: EYE: IMMED FLUSH W/PLENTY OF WATER FOR @ LST 15 MINS.
EYE PROT:& FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:1635F,891C
Spec Gravity:2.29 (H*2O=1)
Solubility in Water:APPRECIABLE (>10%)
Appearance and Odor:WHITE GRANULES. ODORLESS.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, STRONG ACIDS.
Stability Condition to Avoid:MOISTURE, DUSTING, HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE, AND LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: CON A SEPHAROSE 4B, 17-0440-01
Cage: S3515
Resp. Party Other MSDS No.: CH-E-1083-05
=======================================================
Contractor Summary
=======================================================
Cage: S3515
=======================================================
Item Description Information
=======================================================
=======================================================
Ingredients
=======================================================
Cas: 64-17-5
RTECS #: KQ6300000
Percent by Wt: 20.
Other REC Limits: N/K (FP N)
OSHA PEL: 1900 MG/M3;1000 PPM
OSHA STEL: N/K (FP N)
ACGIH TLV: 1880 MG/M3;1000 PPM
ACGIH STEL: N/K (FP N)
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50 (ORAL, RAT): 7060 MG/KG.
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ETHANOL MIGHT HAVE A DRYING AND IRRITATING EFFECT ON THE
SKIN AFTER REPEATED OR PROLONGED EXPOSURE.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
First Aid: INHALATION: REMOVE FROM EXPOSURE. EYES: WASH THOROUGHLY WITH WATER
FOR AT LEAST 15 MINUTES. IF DISCOMFORT PERSISTS, OBTAIN MEDICAL ATTENTION.
SKIN: WASH OFF WITH WATER. INGESTION: WASH OUT MOUTH WITH WATER AND GIVE
WATER TO DRINK.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: WIPE UP AND PLACE IN CONTAINERS FOR DISPOSAL. FLOOR
MAY BE SLIPPERY.
Waste Disposal Methods: DISPOSE AS PER LOCAL, SATE AND FEDERAL REGULATIONS.
Handling And Storage Precautions: STORE GEL SUSPENSION IN THE PRESENCE OF AN
ANTIMICROBIAL AGENT (E.G., 20% ETHANOL).
Other Precautions: EXPOSURE LIMIT: ETHANOL: 500 PPM, 1000 MG/M3 (TLV, SWEDEN).
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point: =39.C, 102.2F
Flash Point Text: ETHANOL
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICALS OR WATER SPRAY.
Fire Fighting Procedures: WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N). USE MEDIA PROPER TO THE PRIMARY CAUSE OF FIRE.
Unusual Fire/Explosion Hazard: NONE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE. WEAR NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN (FP N).
Ventilation: NORMAL VENTILATION.
Other Protective Equipment: EYEWASH AND DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA (FP N).
=======================================================
Physical/Chemical Properties
=======================================================
Solubility in Water: INSOLUBLE
Appearance and Odor: WHITE SUSPENSION; NO ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE.
Materials To Avoid: AVOID CONTACT WITH OXIDIZING AGENTS SUCH AS NITRIC ACID.
Hazardous Decomposition Products: THERMAL DECOMPOSITION MAY YIELD OXIDES OF
CARBON.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
Toxicological Information: PRODUCT IS ESSENTIALLY INERT. NO TOXIC OR ILL
EFFECTS UNDER NORMAL OPERATING CONDITIONS.
=======================================================
Ecological Information
=======================================================
Ecological: NO INFORMATION AVAILABLE.
=======================================================
=======================================================
Transport Information: UN #: 1170. NO DANGEROUS GOODS.
=======================================================
Regulatory Information
=======================================================
Federal Regulatory Information: R 10 = FLAMMABLE.
=======================================================
Other Information
=======================================================
Other Information: PRODUCT DESCRIPTION: AFFINITY CHROMATOGRAPHY MEDIA. CHEMICAL
FAMILY: CONCANAVALIN A COVALENTLY BOUND TO BEAD-FORMED AGAROSE.
=======================================================
HAZCOM Label
=======================================================
Product ID: CON A SEPHAROSE 4B, 17-0440-01
Cage: S3515
Company Name: PHARMACIA BIOTECH AB
Street: S-751 82 UPPSALA
Zipcode: 00000
Label Required IND: Y
Date Of Label Review: 09/29/1999
Status Code: A
Origination Code: F
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: None
Contact Hazard: Slight
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE. ACUTE: ETHANOL MIGHT HAVE A DRYING AND
IRRITATING EFFECT ON THE SKIN AFTER REPEATED OR PROLONGED EXPOSURE. CHRONIC:
NONE LISTED BY MANUFACTURER.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TRIBOLUBE - 19
CAGE:66164
CAGE:66164
============= Composition/Information on Ingredients =============
Ingred Name:MANUFACTURER CLAIMS ONLY NON-HAZARDOUS INGREDIENTS W/O
SPECIFYING ANY INDIVIDUAL INGREDIENT.
Fraction by Wt: 100%
===================== Hazards Identification =====================
LD50 LC50 Mixture:PRODUCT'S LD50 (ORAL RAT) WAS NOT STATED
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-NONE. CHRONIC-NONE
Explanation of Carcinogenicity:MFR GAVE THE ABOVE LISTINGS ON THE MSDS
BUT NO OTHER COMMENTS WERE RECORDED.
Effects of Overexposure:MILD IRRITANT TO THE SKIN UPON PROLONGED
EXPOSURE FOR SOME INDIVIDUALS. DECOMPOSITION PRODUCTS FROMED AT
HIGH TEMPERATURES MAY CAUSE "POLYMER FEVER".
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INHALATION:IF RESPIRATORY DISCOMFORT OCCURS, MOVE TO FRESH
AIR; CONTACT PHYSICIAN. EYES:FLUSH WITH WATER. CONTACT PHYSICIAN.
SKIN:WASH WITH SOAP AND WATER. IF IRRITATION DEVELOPS, CONTACT
PHYSICIAN. I NGESTION:GIVE LARGE AMOUNT OF WATER. CONTACT
PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Fire Fighting Procedures:KEEP CONTAINERS COOL BY SPRAYING WITH WATER
WHEN EXPOSED TO FIRE. WEAR SELF-CONTAINED BREATHING APPARATUS IF
FLAMES HAVE REACHED PRODUCT.
Unusual Fire/Explosion Hazard:PRODUCT WILL NOT BURN BUT THERMALLY
DECOMPOSES ABOVE 290C, YIELDING TOXIC COMPOUNDS.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT MATERIAL TO COLLECT AND CONTAIN
FOR DISPOSAL.
Neutralizing Agent:MFR GAVE NO INFORMATION ON MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE NEAR FLAMMABLES OR
EXPLOSIVE MATERIALS.
Other Precautions:TOXIC VAPORS MAY EVOLVE ABOVE 290C; PROVIDE ADEQUATE
VENTILATION IF USED ABOVE THIS TEMPERATURE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER NORMAL CONDITIONS.
Ventilation:MECHANICAL (GENERAL) VENTILATION & LOCAL EXHAUSE
RECOMMENDED.
Other Protective Equipment:APRON, LAB COAT OR COVERALLS RECOMMENDED.
Work Hygienic Practices:DO NOT CONTAMINATE SMOKING MATERIALS; WASH
HANDS AFTER EXPOSURE.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:V6
NRC/State Lic Num:NONE
Boiling Pt:B.P. Text:NOT APPLY
Melt/Freeze Pt:M.P/F.P Text:NOT APPLY
Decomp Temp:Decomp Text:554F,290C
Vapor Pres:0.001 MM
Vapor Density:NOT APPLY
Spec Gravity:1.880
Solubility in Water:NONE
Appearance and Odor:ODORLESS, WHITE GREASE.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MOLTEN ALKALI METALS, INTERHALOGEN COMPOUDS, STRONG OR NONAQUEOUS
ALKALI AND LEWIS ACIDS ABOVE 100C.
Stability Condition to Avoid:AVOID HEATING ABOVE 290C.
Hazardous Decomposition Products:TOXIC FLUORINE COMPOUNDS.
Conditions to Avoid Polymerization:WILL NOT OCCUR. AVOID HEATING ABOVE
290C.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:GENETRON 22 CHLORODIFLUOROMETHANE
Preparer's Name:NONE
CAGE:0B7T5
CAGE:72658
CAGE:0B7T5
============= Composition/Information on Ingredients =============
Ingred Name:GENETRON 22 CHLORODIFLUOROMETHANE
CAS:75-45-6
RTECS #:PA6390000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9394
Ozone Depleting Chemical:2
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS UNKNOWN.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES/SKIN: LIQUID OR VAPORS MAY
CAUSE FROSTBITE. INHALATION: DISPLACES OXYGEN IN AIR. OXYGEN LEVEL
REDUCED TO 12-14%, SYMPTOMS OF ASPHYXIATION WILL OCCUR, LOSS OF
COORDINATION, INCREASED PULSE RATE, DEEPER RESPIRATION. NARCOTIC
EFFECTS NOTED AT 200,000 PPM. INGESTION: NOT APPLICABLE. CHRONIC:
NONE ESTABLISHED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES/SKIN: FROSTBITE, PALLOR, REDNESS, LOSS OF
SENSATION, SWELLING. INHALATION: ASPHYXIATION, LOSS OF
COORDINATION, INCREASED PULSE RATE, DEEPER RESPIRATION, NARCOTIC
EFFECTS. INGESTION: NOT APPLICABL E, SINCE MATERIAL IS GASEOUS AT
NORMAL TEMPERATURE AND PRESSURE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: BATHE (DO NOT RUB) ANY FROSTBITE WITH LUKEWARM
(NOT HOT) WATER. IN ABSENCE OF WATER, COVER WITH SOFT WOOL OR OTHER
SUITABLE MATERIAL. GET MEDICAL ATTENTION. INHALATION: MOVE TO FRESH
AIR. I F NOT BREATHING, GIVE CPR. IF BREATHINGDIFFICULT, GIVE
OXYGEN. DO NOT GIVE EPINEPHRINE (ADRENALINE). GET MEDICAL
ATTENTION. INGESTION: THIS IS IMPROBABLE DUE TO THE LOW (-40.8C)
BOILING POINT.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:ANY STANDARD AGENT. CHOOSE THE ONE MOST SUITABLE
FOR SURROUNDING FIRE. THIS MATERIAL IS NOT FLAMMABLE.
Fire Fighting Procedures:WHEN MATERIAL IS IN A FIRE, FIREFIGHTERS
SHOULD WEAR SELF-CONTAINED, NIOSH-APPROVED, BREATHING APPARATUS.
USE WATER SPRAY TO KEEP FIRE-EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:CONTACT WITH CERTAIN METALS AND OXIDIZING
MATERIALS MAY PRODUCE EXOTHERMIC REACTIONS OR POTENTIAL EXPLOSIVE
COMBINATIONS. HIGH TEMPERATURES YIELD TOXIC GASES.
================== Accidental Release Measures ==================
Spill Release Procedures:USING A SELF-CONTAINED AIR SUPPLY AND
PROTECTION AGAINST FROSTBITE, PERSONNEL SHOULD ATTEMPT TO CLOSE
VALVES OR REPAIR SOURCE OF LEAK IF WITHOUT RISK. IF LARGE QUANTITY
IS RELEASED, EVACUATE PERSONNEL AND ALLOW TO DISSIPATE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, WELL VENTILATED
AREA AWAY FROM HEAT, FLAME, COMBUSTIBLES. PROTECT CYLINDER/FITTINGS
FROM PHYSICAL DAMAGE.AVOID SUBSURFACE STORAGE.
Other Precautions:DO NOT BREATH GAS, AVOID CONTACT WITH EYES, SKIN,
CLOTHING. DO NOT PUNCTURE OR DROP CYLINDERS OR EXPOSE THEM TO OPEN
FLAME OR EXCESSIVE HEAT. USE AUTHORIZED CONTAINERS ONLY. OBSERVE
SAFETY PRECAUTIONSFOR HANDLING COMPRESSED GAS CYLINDERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE GENERALLY REQUIRED FOR NORMALLY VENTED
SITUATIONS. FOR UNUSUAL SITUATIONS, WEAR A SUPPLIED-AIR RESPIRATOR
OR SELF-CONTAINED BREATHING APPARATUS, NIOSH-APPROVED. AT HIGH
CONCENTRATIONS, ADD A FULLFACEPIECE.
Ventilation:LOCAL EXHAUST AT FILLING ZONES AND WHERE LEAKAGE
PROBABLE.GENERAL VENTILATION ADEQUATE FOR OTHER OPERATING/STORAGE
AREAS
Other Protective Equipment:PROVIDE WATER SOURCE FOR FIRST-AID TREATMENT
INSULATED.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
PRODUCT CAN CAUSE DEATH OR SERIOUS PERSONAL INJURY IF NOT HANDLED
PROPERLY. FOLLOW OSHA REGULATIONS FOR COMPRESSED GASES (29CFR
1910.101) AND REFERENCE (D) FOR CYLINDER HANDLING. MIXTURES OF
GENETRON 22 AND AIR, UNDER PRESSURE OF 200 PSIG OR HIGHER, HAVE
BEEN OBSERVED TO IGNITE AND BURN, GENERATING EXPLOSIVE PRESSURES.
================== Physical/Chemical Properties ==================
HCC:G3
Boiling Pt:B.P. Text:-41F,-41C
Melt/Freeze Pt:M.P/F.P Text:-256F,-160C
Vapor Pres:136 PSIA
Vapor Density:2.98
Spec Gravity:1.21
pH:7
Solubility in Water:SLIGHT
Appearance and Odor:COLORLESS LIQUEFIED GAS WITH FAINT ETHEREAL ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS, ALKALI METALS, ALKALI EARTH METALS, FRESHLY EXPOSED
ALUMINUM SURFACES.
Stability Condition to Avoid:FLAMES, LIGHTED CIGARETTES, HOT SPOTS,
WELDING. DECOMPOSES AT HIGH TEMPERATURES, YIELDING TOXIC GASES.
Hazardous Decomposition Products:HALOGENS, HALOGEN ACIDS, CARBON
MONOXIDE, CARBON DIOXIDE, CARBONYL HALIDES SUCH AS PHOSGENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS. DO NOT VENT TO ATMOSPHERE. TO COMPLY WITH PROVISIONS
OF U.S.CLEAN AIR ACT, ANY RESID UAL MUST BE RECOVERED.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ADX 3126 PART B
Kit Part:Y
Preparer's Name:SUZANNE FRANZ
CAGE:33564
CAGE:33564
============= Composition/Information on Ingredients =============
Ingred Name:DIETHYLENE TRIAMINE
CAS:111-40-0
RTECS #:IE1225000
Fraction by Wt: <10%
OSHA PEL:1 PPM
ACGIH TLV:1 PPM, S
Ingred Name:ALKYLAMINES
Ingred Name:SILICA
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: <70%
Other REC Limits:20 MPPCF (MFR)
Ingred Name:VOLATILE ORGANIC COMPOUNDS
RTECS #:9999999VO
Fraction by Wt: 10% G/L
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE & CHRONIC:MATERIAL IS CORROSIVE
TO SKIN. MAY CAUSE CHEMICAL BURNS & POSSIBLE SENSITIZATION TO SKIN.
VAPORS IRRITATING & MAY CAUSE BRONCHITIS SYMPTOMS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:POSSIBLE BURNS TO EYES & SKIN; IRRITATION &
POSSIBLE SENSITIZATION TO SKIN. VAPORS IRRITATING & MAY CAUSE
BRONCHITIS SYMPTOMS.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . SKIN:FLUSH W/PLENTY OF
WATER. WASH THOROUGHLY W/SOAP & WATER, RUBBING ALCOHOL OR HAND
CLEAN ER. DO NOT USE SOLVENTS. REMOVE SOILED CLTHG & WASH BEFORE
REUSE. IF IRRITATION PERSISTS, SEE MD. EYE:FLUSH W/PLENTY OF WATER
FOR AT LEAST 15 MINUTES. IF IRRITATION PERSISTS, SEE MD.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:>300F,>149C
Extinguishing Media:DRY CHEMICAL,HALON FIRE EXTINGUISHER,H*2O
SPRAY,FOAM/FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:DENSE SMOKE & TOXIC GASES MAY BE
LIBERATED.
================== Accidental Release Measures ==================
GLASSES. SCRAPE UP & TRANSFER TO METAL CONTAINER. WIPE UP REMAINING
RESIDUE W/SOLVENTS, OBSERVING SOLVENT FLAMMABILITY CAUTIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP COOL I/A/W LABEL INSTRUCTIONS.
FOLLOW RECOMMENDED CURING SCHEDULE. STORE AT ROOM TEMPERATURE (77F)
FOR 12 MONTHS.
Other Precautions:CORROSIVE. AVOID CONTACT. KEEP CONTAINER CLOSED. USE
ONLY W/GOOD VENTILATION. DO NOT CUT OR WELD CONTAINERS. DO NOT USE
UNTIL MSDS HAS BEEN READ & UNDERSTOOD.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NOT NEEDED W/GOOD INDUSTRIAL VENTILATION.
Ventilation:LOCAL EXHAUST RECOMMENDED.
Other Protective Equipment:EMERGENCY EYE WASH & DELUGE SHOWER . OTHER
PROTECTIVE EQUIPMENT AS NEEDED TO PROTECT SKIN & CLOTHING.
Work Hygienic Practices:WASH AFTER HANDLING. REMOVE CONTAMINATED
CLOTHING & THOROUGHLY CLEAN BEFORE REUSE.
Supplemental Safety and Health
CNDTNS (POLYM):BONDED. FAILURE TO OBSERVE CAUTION MAY RESULT IN
EXCESSIVE HEAT BUILD-UP W/RELEASE OF TOXIC GASES.
================== Physical/Chemical Properties ==================
HCC:V7
Boiling Pt:B.P. Text:DECOMPOSES
Spec Gravity:0.96
Solubility in Water:SLIGHTLY
Appearance and Odor:AMBER LIQUID W/AMMONICAL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS,STRONG LEWIS/MINERAL ACIDS.
Hazardous Decomposition Products:CO,NO*X,ALDEHYDES,ACIDS & UNDETERMINED
ORGANICS.
Conditions to Avoid Polymerization:AVOID MIXING RESIN & CURING AGENT IN
BATCHES >1 LB TOTAL. DO NOT HEAT MIXED ADHESIVE UNLESS CURING SURFS
TO BE (SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AS HAZARDOUS WASTE ACCORDING TO
FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SCOTCHCAST BRAND 4 ELECTRICAL INSULATING RESIN, PART B
Kit Part:Y
Resp. Party Other MSDS Num.:10-2577-4
CAGE:75037
CAGE:76381
CAGE:75037
============= Composition/Information on Ingredients =============
Ingred Name:NONYLPHENOL
CAS:25154-52-3
RTECS #:SM5600000
Minumum % Wt:35.
Maxumum % Wt:45.
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMINE/FATTY ACID ADDUCT
CAS:68919-79-9
Minumum % Wt:15.
Maxumum % Wt:20.
Other REC Limits:NONE RECOMMENDED
Ingred Name:EXTRACTS, HEAVY NAPHTHENIC DISTILLATE SOLVENT PETROLEUM
CAS:64742-11-6
RTECS #:PY8042000
Minumum % Wt:13.
Maxumum % Wt:15.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:N-AMINOETHYLPIPERAZINE
CAS:140-31-8
RTECS #:TK8050000
Minumum % Wt:10.
Maxumum % Wt:13.
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMINE/EPOXY RESIN ADDUCT
CAS:70776-37-3
Minumum % Wt:10.
Maxumum % Wt:15.
Other REC Limits:NONE RECOMMENDED
Ingred Name:AROMATIC HYDROCARBONS, C12-20
CAS:70955-17-8
Minumum % Wt:3.
Maxumum % Wt:5.
Other REC Limits:NONE RECOMMENDED
Ingred Name:2,4,6-TRIS(DIMETHYLAMINO METHYL) PHENOL
CAS:90-72-2
RTECS #:SN3500000
Minumum % Wt:2.
Maxumum % Wt:5.
Other REC Limits:NONE RECOMMENDED
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Minumum % Wt:1.
Maxumum % Wt:3.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9596
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT: CHEMICAL RELATED EYE
BURNS (CHEMICAL CORROSIVITY). SKIN CONTACT: ALLERGIC SKIN REACTION.
SKIN BURNS. MAY BE ABSORBED THROUGH THE SKIN AND PRODUCE EFFECTS
SIMILAR TO THOSE CAUSED BY INHALA TION AND/OR INGESTION.
INHALATION: ALLERGIC RESPIRATORY REACTION. IRRITATION (UPPER
RESPIRATORY). IF SWALLOWED: IRRITATION OF GASTROINTESTINAL TISSUES.
BURNS OF THE ORAL TISSUES.
Explanation of Carcinogenicity:CONTAINS A CHEMICAL WHICH CAN CAUSE
CANCER (CAS# 64742-1-6) (IARC HUMAN CACINOGEN 1 FOR UNTREATED AND
MILDY TREATED AND IARC NOT CLASSIFIABLE AS TO CARCINOGENICITY TO
HUMANS 3).
Effects of Overexposure:EYES:CLOUDY APPEARANCE OF THE CORNEA,CHEMICAL
BURNS,PAIN,TEARING,ULCERS,IMPAIRED VISION OR LOSS OF
VISION.ALLERGIC SKIN
REACTION:REDNESS,SWELLING,BLISTERING,ITCHING.SKIN
BURNS:REDNESS,SWELLING,BLISTER ING,ULCERATION,SLOUGHING,SCAR
FORMATION.INHALATION: ALLERGIC RESPIRATORY REACTION:DIFFICULTY
BREATHING,WHEEZING,TIGHTNESS OF CHEST, RESPIRATORY
FAILURE.IRRITATION (UPPER RESPIRATORY):SORENESS OF NOSE &
THROAT,COUGHING & SNEEZING.SWALLOWED:IRRITATION OF GI
TISSUES:PAIN,VOMITING,ABDOMINAL TENDERNESS,NAUSEA,BLOOD IN
VOMITUS,BLOOD IN FECES.BURNS TO ORAL TISSUE:PAIN,BURNS OF TONGUE &
INSIDES OF MOUTH,R EDNESS, TISSUE LOSS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE CONTACT: IMMEDIATELY FLUSH WITH LARGE AMOUNTS OF WATER
FOR AT LEAST 15 MINUTES. GET IMMEDIATE MEDICAL ATTENTION. SKIN
CONTACT: IMMEDIATELY FLUSH WITH LOTS OF WATER FOR AT LEAST 15
MINUTES IN A CHE MICAL SAFETY SHOWER WHILE REMOVING CONTAMINATED
CLOTHES & SHOES. GET IMMEDIATE MEDICAL ATTENTION. INHALATION: IF
SIGNS/SYMPTOMS OCCUR, REMOVE PERSON FRESH AIR. IF SIGNS/SYMPTOMS
OCCUR, CALL A PHYSICIA N. IF SWALLOWED: DO NOT INDUCE VOMITING!
GIVE VICTIM 2 GLASSES WATER. CALL PHYSICIAN IMMEDIATELY. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>110.C, 230.F
Autoignition Temp:Autoignition Temp Text:ND
Lower Limits:ND
Upper Limits:ND
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING INCLUDING
HELMET, SELF-CONTAINED POSITIVE PRESSURE OR PRESSURE DEMAND
BREATHING APPARATUS, BUNKER COAT, PANTS, BANDS AROUND ARMS, WAIST
AND LEGS, FACE MASK, AND PROTECTIV E COVERING FOR EXPOSED AREAS OF
HEAD.
Unusual Fire/Explosion Hazard:NO UNUSUAL FIRE OR EXPLOSION HAZARDS ARE
ANTICIPATED. OSHA FIRE HAZARD CLASS IIIB COMBUSTIBLE LIQUID.
================== Accidental Release Measures ==================
Spill Release Procedures:OBSERVE PRECAUTIONS FROM OTHER SECTIONS. COVER
WITH ABSORBENT MATERIAL. COLLECT SPILLED MATERIAL. PLACE IN AN
APPROVED METAL CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM ACIDS. STORE AWAY FROM
HEAT. KEEP OUT OF REACH OF CHILREN. KEEP AWAY FROM HEAT, SPARKS,
OPEN FLAME AND OTHER IGNITION SOURCES.
Other Precautions:PREVENT ALL SOURCES OF IGNITION. COMBUSTIBLE LIQUID
AND VAPOR. NO SMOKING WHILE HANDLING THIS MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID PROLONGED BREATHING OF VAPORS.
Ventilation:PROVIDE SUFFICIENT VENTILATION TO MAINTAIN EMISSIONS BELOW
RECOMMENDED EXPOSURE LIMITS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH CONTAMINATED CLOTH BEFORE REUSE.WASH HANDS
AFTER HANDLING, BEFORE EATING. AVOID EYE/SKIN CONTACT.
Supplemental Safety and Health
DLA-HMIS NOTE: PART B OF A TWO PART KIT. PART A IS DOD-HMIS SERIAL
NUMBER CKXKJ.
================== Physical/Chemical Properties ==================
HCC:V5
Melt/Freeze Pt:M.P/F.P Text:N/D
Vapor Density:NA
Spec Gravity:0.98
pH:NA
Viscosity:3500 CPS
Solubility in Water:NIL
Appearance and Odor:BLACK LIQUID, AMINE ODOR
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:ALDEHYDES, HYDROCARBONS, IRRITATING
VAPORS & GASES.OXIDES OF NITROGEN, CARBON MONOXIDE, CARBON DIOXIDE.
OTHER SUBSTANCES THAT COULD BE GENERATED ARE ALKYLATED PHENOLS,
BENZENE, ALKYLATED AMINES, CRESOLS
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:NO DATA PROVIDED BY MANUFACTURER
===================== Ecological Information =====================
Ecological:NO DATA AVAILABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:CURE PRODUCT ACCORDING TO PRODUCT INSTRUCTIONS.
INCINERATE UNCURED WASTE IN AN INDUSTRIAL OR COMMERCIAL
INCINERATOR. DISPOSE OF COMPLETELY CURED (OR POLYMERIZED) MATERIAL
IN A SANITARY LANDFILL.
=================== MSDS Transport Information ===================
Transport Information:NO DATA PROVIDED BY MANUFACTURER.
===================== Regulatory Information =====================
SARA Title III Information:EPCRA HAZARD CLASS: FIRE HAZARD: NO,
PRESSURE: NO, REACTIVITY: NO, ACUTE: YES, CHRONIC: YES.
Federal Regulatory Information:SINCE REGULATIONS VARY, CONSULT
APPLICABLEE REGULATIONS OR AUTHORITIES BEFORE DISPOSAL. U.S. EPA
HAZARDOUS WASTE NUMBER: NONE (NOT US EPA HAZARDOUS). VOLATILE
ORGANIC COMPOUNDS: N/D. VOC LESS H20 & EX EMPT SOLVENTS: N/D. NOTE:
THIS MATERIAL CONTAINS ONE OR MORE SUBSTANCES NOT LISTED ON THE
TSCA INVENTORY AND IS MANUFACTURED FOR EXPORT ONLY. WITHIN THE
UNITED STATES, IT MAY ONLY BE USED FOR R&D PURP OSES. ALL
INGRDIENTS LISTED ON TSCA, AICS, AND DSL INVENTORIES.
State Regulatory Information:NO DATA PROVIDED BY MANUFACTURER
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:196 7611 K-LAB YELLOW DEVELOPER, PART B (BOTTLE 2), K-14M
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 85-90%
Other REC Limits:NONE RECOMMENDED
Ingred Name:HEXYLENE GLYCOL
CAS:107-41-5
RTECS #:SA0810000
Fraction by Wt: 10-15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 25 PPM
ACGIH TLV:C 25 PPM; 9596
Ingred Name:AMMONIUM BROMIDE
CAS:12124-97-9
RTECS #:BO9170000
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMMONIUM NITRATE
CAS:6484-52-2
RTECS #:BR9050000
Fraction by Wt: 8%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SUCCINIC ACID
CAS:110-15-6
RTECS #:WM4900000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): NOT GIVEN
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. MAY CAUSE TRANSIENT EYE IRRITATION. LOW
SKIN CONTACT HAZARD FOR RECOMMENDED HANDLING. EXPECTED TO BE A LOW
INGESTION HAZARD.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMMEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL
FOAM
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY PRODUCE
HAZARDOUS DECOMPOSTION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER IF ALLOWABLE WITH LARGE AMOUNTS
OF WATER. OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT
MATERIAL, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN
SURFACE TO REMOVE RESIDUA L CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION. WASH
THOROUGHLY AFTER HANDLING. KEEP FROM CONTACT WITH OXIDIZING
MATERIALS. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:KEEP AWAY FROM INCOMPATIBLE MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:0.6
Spec Gravity:NOT GIVEN
pH:8.5
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID, CHARACTERISTIC ODOR
Percent Volatiles by Volume:90-100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. MAY REQUIRE NEUTRALIZATION IF PH
< 2.0 OR PH > 12.5. DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE ANDLOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LUBRICATING OIL,EXPOSED GEAR,VV-L-751
CAGE:FO626
CAGE:5A565
CAGE:FO626
============= Composition/Information on Ingredients =============
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
Effects of Overexposure:MILD IRRITANT TO SKIN & EYES.
======================= First Aid Measures =======================
First Aid:EYE-FLUSH W/WATER 15 MIN;SKIN-WASH W/SOAP & WATER. INGEST-DO
NOT INDUCE VOMITING,GET MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:430F/221C/COC
Extinguishing Media:WATER FOG,CARBON DIOXIDE,DRY CHEMICAL,FOAM
Fire Fighting Procedures:WATER MAY CAUSE FROTHING
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/SAND OR INERT MATERIAL. SWEEP OR
SCOOP UP & REMOVE
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM SPARKS & OPEN FLAMES.
WASH THOROUGHLY AFTER HANDLING. DO NOT GET IN EYES, ON CLOTHING.
============= Exposure Controls/Personal Protection =============
Ventilation:PROVIDE ADEQUATE VENT.
Supplemental Safety and Health
VV-L-751,TYPE II,GRADE 1
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:700F/371C
Spec Gravity:0.91
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DARK,VISCOUS OIL,BLAND
Percent Volatiles by Volume:NEG
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE W/INCOMPLETE
COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT FED,STATE & LOCAL AUTHORITIES.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:AR11-L117A JD IND 10% YELLOW
CAGE:DO662
CAGE:SPRPR
CAGE:DO662
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT; (ODORLESS MIN SPIRITS) LEL: 0.7%
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 15%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:HYDROCARBONS, C7-9; (V M & P NAPHTHA) LEL: NONE
CAS:68920-06-9
Fraction by Wt: 10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TOLUENE (SARA 313) (CERCLA) LEL: 1.4%
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <5%
OSHA PEL:200 PPM
ACGIH TLV:50 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PROPIONIC ACID, 3-ETHOXY, ETHYL ESTER; (ETHYL
-ETHOXYPROPIONATE) LEL: 1.0%
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: <5%
OSHA PEL:50 PPM (MFR)
ACGIH TLV:50 PPM (MFR)
Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE) (SARA 313) (CERCLA) LEL:
1.8%
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 5%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM/300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETONE (SARA 313) (CERCLA) LEL: 2.6%
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 20%
OSHA PEL:1000 PPM
ACGIH TLV:750 PPM/1000 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:N-BUTYL ALCOHOL; (N-BUTANOL) (SARA 313) (CERCLA) 1.4%
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: <5%
OSHA PEL:100 PPM
ACGIH TLV:C 50 PPM, S
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPANE, 2-METHYL-; (ISOBUTANE) LEL: 1.8%
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 15%
OSHA PEL:1000 PPM (MFR)
ACGIH TLV:1000 PPM (MFR)
Ingred Name:PROPANE. LEL: 2.3%
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 15%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IN CONFINED AREA VAPS IN HIGH
CONC ARE ANESTH, IRRIT TO SKIN & UPPER RESP SYS. OVEREXP MAY RSLT
IN LT-HEAD, STAG GAIT, GIDD & POSS NAUS. CONTAINS PETRO DISTILS -
HARMFUL/FATAL IF SWALLOWED. CHR ONIC: RPTS HAVE ASSOC RPTD & PRLNG
OVEREXP TO SOLVS W/PERM BRAIN & NERV SYS DMG, ALSO KIDNEY & LIVER
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: DMG. TOLUENE APPEARS ON THE NAVY
OCCUP CHEM REPRO HAZ LIST. SEEK CONSULT FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG & EXPOS
INFO .
Medical Cond Aggravated by Exposure:NONE ESTABLISHED.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE PATIENT TO FRESH AIR. EYES: FLUSH WITH
WATER FOR AT LEAST 15 MINUTES. SKIN: WASH WITH SOAP AND WATER.
INGESTION: CALL MD IMMEDIATELY. DO NOT INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:<20.0F,<-6.7C
Lower Limits:SEE INGS
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER MAY BE INEFFECTIVE. WATER MAY BE USED TO KEEP
FIRE-EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:DO NOT SPRAY NEAR OPEN FLAME. KEEP AT
ROOM TEMPERATURE AS EXPOSURE TO DIRECT SUNLIGHT OR OTHER HEAT MAY
CAUSE BURSTING.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE.
AVOID BREATHING VAPORS AND REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. KEEP AT ROOM
TEMPERATURE AS EXPOSURE TO DIRECT SUNLIGHT OR HEAT MAY CAUSE
BURSTING.
Other Precautions:KEEP AWAY FROM CHILDREN. DO NOT PUNCTURE OR
INCINERATE. DO NOT SPRAY NEAR FIRE OR OPEN FLAME.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID BRTHG OF VAP/SPRAY MIST. IF PERS EXPOS
CANNOT BE CONTROLLED BELOW APPLIC LIMITS BY VENT, WEAR PROPERLY
FITTED ORG VAP/PARTICULATE RESP APPRVD BY NIOSH. WHEN
SANDING/ABRADING DRIED FILM, WEAR DUS T/MIST RESP APPRVD BY NIOSH
(SUP DAT)
Ventilation:PROVIDE LOC EXHST VENT IN VOL & PATTERN TO KEEP TLV OF ALL
HAZ INGS BELOW ACCEPTABLE LIM, & LEL BELOW STATED LIMIT.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
VP: 55 +/- 5 PSIG. RESP PROT: FOR DUST WHICH MAY BE GENERATED FROM THIS
PROD, UNDERLYING PAINT/ABRASIVE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:<0F,<-18C
Vapor Pres:SUP DAT
Vapor Density:HVR/AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:COATINGS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:DO NOT STORE ABOVE 120F.
Hazardous Decomposition Products:BY OPEN FLAME: CARBON MONOXIDE, CARBON
DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE - DISPOSE IN ACCORDANCE WITH
FEDERAL, STATE, AND LOCAL REGULATIONS REGARDING POLLUTION.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:9111 (CLEANER/DEGREASER), 1202/0988/05
Preparer's Name:2. FAUPEL
CAGE:67020
CAGE:0PX05
CAGE:67020
============= Composition/Information on Ingredients =============
Ingred Name:AROMATIC HYDROCARBONS; (C11-C15 AROMATIC HYDROCARBON)
CAS:90622-58-5
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPP DATA:NON-EXPLOSIVE MAY YIELD TOXIC &/OR CORROSIVE
DECOMPOSITION PRODUCTS.
RTECS #:9999999ZZ
Ingred Name:OTHER PROT EQUIP:WHERE THERE IS A RISK OF CONTAMINATION OF
FOOTWEAR, SAFETY BOOTS SHOULD BE WORN.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION, PRODUCT VAPORS DISPLACE
AIR AND CAN CAUSE ASPHYXIATION ESPECIALLY IN CONFINED SPACES.
ACUTE:SKIN, EYE AND RESPIRATORY TRACT IRRITANT. AT LOW
CONCENTRATION, INHALATION OF VAPORS MAY CAUSE H EADACHE, DIZZINESS,
NAUSEA, LOSS OF CONCENTRATION AND IRRITATION. AT HIGHER
CONCENTRATIONS, INHALATION (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:MAY RESULT IN INTOXICATION, CARDIAC
ARRHYTHMIA, ETC. CHRONIC:IRRITATION, DRYNESS/FLAKING OF SKIN AND
DERMATITIS.
Medical Cond Aggravated by Exposure:SKIN, EYE & RESPIRATORY TRACT
CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE VICTIM TO FRESH AIR. KEEP AFFECTED PERS WARM & AT
REST. IF RECOVERY IS DELAYED/THERE ARE SIGNS OF DISTRESS, OBTAIN
MED ATTN IMMED. EYES:FLUSH W/WATER FOR AT LST 15 MINS. SEEK MED
ADVICE IF ANY IRRIT PERSISTS. SKIN:IMMED REMOVE EXCESS W/CLEAN
CLOTH & APPLY MOISTURIZING CREAM. IF IRRIT/INFLAMM PERSISTS, SEEK
MED ADVICE. INGEST:DO NOT INDUCE VOMIT. RINSE MOUTH W/WATER & DRINK
(SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:145F,63C
Lower Limits:0.6%
Upper Limits:7%
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE . USE SAND TO
CONTAINS BURNING MATERIAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONFLAMMABLE, HOWEVER VAPORS CAN FORM
EXPLOSIVE MIXTURE W/AIR. DECOMPOSITION (>250C) & COMBUSTION
PRODUCTS WILL BE HAZARDOUS.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE WELL & STOP FLOW OF LIQUID. DO NOT
ALLOW TO ENTER WATER COURSES. ABSORB W/INERT MATERIAL (E.G., EARTH
OR SAND). SWEEP UP & PLACE INTO SUITABLE LABELLED CONTAINERS, SEAL
& DISPOSE OF PROPERLY .
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING VAPORS & CONTACT
W/SKIN & EYES. OVERHEATING MAY CAUSE CONTAINERS TO RUPTURE.
CONTAINERS SHOULD BE STORED UNDER COOL, DRY CONDITIONS.
Other Precautions:EMPTY CONTAINERS WILL RETAIN RESIDUE & MAY BE
DANGEROUS. CHECK ALL CONTAINERS FOR LEAKS AT REGULAR INTERVALS &
BEFORE USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN CONFINED AREAS OR WHERE GOOD
NATURAL/MECHANICAL VENTILATION IS NOT AVAILABLE, LEADING TO RISK OF
EXCEEDING TLV'S INDICATED, AN APPROPRIATE NIOSH APPROVED RESPIRATOR
SHOULD BE WORN.
Ventilation:WHERE ADEQUATE NATURAL VENTILATION IS NOT AVAILABLE PROVIDE
SUITABLE LOCAL EXHAUST VENTILATION.
Other Protective Equipment:ANSI APPRVD EYE WASH FOUNTAIN & DELUGE
SHOWER . USE HAND CREAM. SUITABLE PROT CLTHG TO MIN SKIN CONT.
(SUPP DATA)
Work Hygienic Practices:WHEN USING, DO NOT EAT, DRINK/SMOKE. REMOVE
CONTAM CLTHG & LAUNDER BEFORE REUSE. WASH HANDS W/SOAP & WATER
AFTER (ING 3)
Supplemental Safety and Health
MATLS TO AVOID:POTASSIUM, CALCIUM, MAGNESIUM, ZINC, BARIUM & LITHIUM
SHAVINGS. FIRST AID PROC:PLENTY OF WATER. CALL TAMPA BAY REGIONAL
:NEOPRENE/PVC. HYGIENE PRACT:HNDLG THISPROD. CNDTNS
(STAB):CIGARETTES. EXPLOSIONS MAY RESULT IN FLAMM RANGE. (ING 2)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>361F,>183C
Vapor Pres:<1 @ 25C
Vapor Density:>1
Spec Gravity:0.77
Solubility in Water:0.1% @ 20C
Appearance and Odor:CLEAR, COLORLESS LIQUID W/SOLVENT ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ACIDS & BASES. REACTIVE METALS I.E.
POWDERED/FRESHLY ABRADED ALUMINUM, SODIUM, (SUPP DATA)
Stability Condition to Avoid:STORE <30C DUE TO LOW BOILING POINT. AVOID
SOURCES OF IGNIT SUCH AS SPARKS, HOT SPOTS, WELDING, FLAME & (SUPP
DATA)
Hazardous Decomposition Products:GASEOUS COMBINATIONS OF CARBON,
HYDROGEN, CHLORINE, FLUORINE & OXYGEN MAY OCCUR AT ELEVATED
TEMPERATURES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ENVIROCARE WASHROOM/FIXTURE CLEANER
CAGE:NO619
CAGE:NO619
CAGE:94525
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM CITRATE, NONHAZARDOUS
CAS:68-04-2
Other REC Limits:NONE RECOMMENDED
Ingred Name:ALKYL POLYGLYCOCIDE SURFACTANT, NONHAZARDOUS
CAS:113976-90-2
Other REC Limits:NONE RECOMMENDED
Ingred Name:FOOD BLUE NUMBER 2 DYE, NONHAZARDOUS
CAS:3844-45-9
Other REC Limits:NONE RECOMMENDED
Ingred Name:FOOD YELLOW NUMBER 4 DYE, NONHAZARDOUS
CAS:1934-21-0
Other REC Limits:NONE RECOMMENDED
Ingred Name:FRAGRANCE, NONHAZARDOUS
Other REC Limits:NONE RECOMMENDED
Ingred Name:CONTAINS NO HAZARDOUS INGREDIENTS AS DEFINED IN OSHA 24 CFR
1910.1200.
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INCIDENTAL SKIN CONTACT IS NOT
EXPECTED TO CAUSE ANY SIGNIFICANT IRRITATION. PROLONGED SKIN/EYE
CONTACT MAY PRODUCE MILD IRRITATION. INHALATION OF MIST/VAPOR MAY
IRRITATE UPPER RESPIR. TRACT.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER 15 MINUTES. SKIN: WASH W/SOAP AND WATER.
INHALATION: REMOVE TO FRESH AIR. INGESTION: CONSULT DR.
===================== Fire Fighting Measures =====================
Flash Point:NK, NONREACTIVE
Extinguishing Media:NOT CONSIDERED FIRE HAZARD, NOR WILL IT SUPPORT
COMBUSTION.
Fire Fighting Procedures:USE STANDARD FIRE-FIGHTING TECHNIQUES TO
EXTINGUISH FIRES INVOLVING THIS MATERIAL. WATER SPRAY/DRY
CHEMICAL/FOAM.
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER LIQ W/WET MOP/WET-DRY VAC. FLUSH
RESIDUE TO SANITARY SEWER W/WATER. USE CARE IF FLOOR BECOMES
SLIPPERY.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM CHILDREN. AVOID EYE AND
PROLONGED SKIN CONTACT. IN SPRAY APPLICATIONS, USE W/ ADEQUATE
VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ADEQUATE VENTILATION IS NECESSARY.
Ventilation:ADEQUATE VENTILATION IS NECESSARY.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:1.060 8.8LBS/GL
pH:4.0
Solubility in Water:COMPLETE.
Appearance and Odor:FREE-FLOWING GREEN LIQUID, PLEASANT GREEN GRASS
FRAGRANCE.
Percent Volatiles by Volume:85.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:GRAM DECOLORIZER, 2000.82, 2000.113, 2000.826
Preparer's Name:ERIC SISSON
CAGE:64424
CAGE:64424
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE
CAS:67-64-1
RTECS #:AL3150000
= Wt:50.
ACGIH TLV:750 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHANOL (DENATURED)
CAS:64-17-5
RTECS #:KQ6300000
= Wt:50.
ACGIH TLV:N AP
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EFFECTS OF OVEREXPOSURE: CONTACT WITH
EYES MAY CAUSE IRRITATION OR TISSUE DAMAGE. CONTACT WITH SKIN MAY
CAUSE IRRITATION. PRINCIPLE ROUTES OF ENTRY: CONTACT.
Explanation of Carcinogenicity:N AP
Effects of Overexposure:SEE HEALTH HAZARDS .
======================= First Aid Measures =======================
First Aid:IMMEDIATELY FLUSH EYES AND SKIN WITH COPUIOUS AMOUNTS OF
WATER FOR AT LEAST 15 MINUTES. IN CASE OF EYE EXPOSURE, CALL A
PHYSICIAN.INGESTION: CONTACT PHYSICIAN IMMEDIATELY . INHALATION:
REMOVE TO FRESH AIR. SUPPORT BREATHING. CONTACT PHYSICIAN
IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:=12.C, 53.6F
Lower Limits:2.0
Upper Limits:12.8
Extinguishing Media:USE CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:N AP.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE SOURCES OF IGNITION, WIPE UP WITH A
DAMP SPONGE OR MOP AND FLUSH DOWN DRAIN WITH PLENTY OF WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT HANDLE OR STORE NEAR FLAME,
HEAT OR STRONG OXIDANTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH APPROVED RESPIRATOR APPROPRIATE FOR THE
EXPOSURE OF CONCERN. .
Ventilation:LOCAL EXHAUST: PREFERRED. MECHANICAL (GENERAL): YES.
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA .
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:=56.1C, 133.F
B.P. Text:56.1-82C, 133-180F
Vapor Pres:186 MM HG.
Vapor Density:2.0 -2.1
Spec Gravity:0.79
Evaporation Rate & Reference:2.4 - 14.48 (NO REF PROV)
Solubility in Water:COMPLETE.
Appearance and Odor:CLEAR, COLORLESS LIQUID WITH SLIGHTLY PUNGENT ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
IGNITION SOURCES AND STRONG OXIDIZERS.
Stability Condition to Avoid:N AP.
Hazardous Decomposition Products:N AP.
=================== Toxicological Information===================
Toxicological Information:ACETONE LD50: 3000 MG/KG (OR - MOUSE).
ETHANOL (DENATURED) LDLO: 340 MG/KG (OR - HUMAN). THRESHOLD LIMIT
VALUE: 453 PPM. PERMISSIBLE EXPOSURE LIMIT: N AP.
==================== Disposal Considerations ====================
Waste Disposal Methods:ALWAYS DISPOSE OF MATERIAL ACCORDING TO ALL
FEDERAL, STATE AND LOCAL REGULATIONS.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:C-1140-T INVISIBLE, 1140T
Preparer's Name:CHARLES B DOTY
CAGE:CHIG0
CAGE:CHIG0
============= Composition/Information on Ingredients =============
Ingred Name:NON HAZARDOUS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION HEALTH RISKS AND SYMPTOMS
OF EXPOSURE: NO IRRITATION WHEN USED AT ROOM TEMPERATURE. SKIN AND
EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE: SKIN CONTACT
NON-IRRITATING. EYE CONTACT MAY BE SLIGHTLY IRRITATING. SKIN
ABSORPTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE: NOT LIKELY TO BE
ABSORBED THROUGH SKIN. INGESTION HEALTH RISKS AND SYMPTOMS OF
EXPOSURE: LOW TOXICITY BY INGESTION. HOWEV ER, IT SHOULD NOT BE
TAKEN INTERNALLY, OR USED ON FOOD PRODUCTS. NO ACUTE OR CHRONIC
HEALTH HAZARDS CURRENTLY KNOWN.
Explanation of Carcinogenicity:NONE CURRENTLY KNOWN.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE CURRENTLY KNOWN.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN: WASH
WITH SOAP AND WATER. CONSULT A PHYSICIAN IF IRRITATION PERSISTS.
INGESTION: IF LARGE QUANTITIES ARE INGESTED, DRINK WATER TO DILUTE,
INDUCE V OMITING.
===================== Fire Fighting Measures =====================
Flash Point Method:OC
Flash Point:=148.9C, 300.F
Extinguishing Media:NONE KNOWN. USE MEDIA SUITABLE FOR SURROUNDING FIRE
.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT
EXPLOSION WHEN EXPOSED TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:WASH WITH WATER OR REMOVE BY SUITABLE INERT
ABSORBING MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID EXCESSIVE INHALATION OF VAPOR OR
MIST.
Other Precautions:IN ACCORDANCE WITH GOOD INDUSTRIAL PRACTICE, HANDLE
WITH CARE AND AVOID UNNESSARY CONTACT. FOR INDUSTRIAL USE ONLY.
HMIS PERSONAL PROETECTIVE EQUIPMENT IS DEPENDENT UPON CONDITIONS OF
USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. USE NIOSH APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE REQUIRED.
CONTACT IS LIKELY.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER . NONE REQUIRED.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. FOR INDUSTRIAL
USE ONLY. WASH HANDS BEFORE EATING, DRINKING OR SMOKING. AVOID
SMOKING IN WORK AREA.
Supplemental Safety and Health
HMIS CODES: H=0, F=1,R=0,P .
================== Physical/Chemical Properties ==================
Boiling Pt:>100.C, 212.F
B.P. Text:212-350F
Vapor Density:HVR/AIR
Spec Gravity:1.0 (H*2O = 1)
VOC Grams/Liter:2.12
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SOLUBLE
Appearance and Odor:MODERATELY VISCOUS, PARTICALLY ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE KNOWN.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN COMPLIANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS. REFER TO MSDS CAUTION INFORMATION BEFORE ATTEMPTING
CLEANUP.
=================== MSDS Transport Information ===================
Transport Information:D.O.T. PROPER SHIPPING NAME: ADHESIVES. HAZARDOUS
SUBSTANCE 49 CFR CERCLA: N/A. HAZARD CODE: N/A. D.O.T. HAZARD
CLASS: NOT REGULATED. D.O.T. LABELS REQUIRED: N/A. D.O.T. PLACARDS
REQUIRED: N/A. POISON CONSTITUENT: N/A. BILL OF LADING
DESCRIPTION: ADHESIVES. CC NO: N/A. UN/NA CODE: N/A. CHEMICAL
EMERGENCY: CHEMTREC 24 HOURS: 1-800-424-9300.
===================== Regulatory Information =====================
SARA Title III Information:NO TOXIC CHEMICAL(S) SUBJECT TO THE
REPORTING REQUIREMENTS OF SECTION 313 OF TITLE III AND OF 40 CFR
372 ARE PRESENT.
Federal Regulatory Information:THIS INK CONTAINS NO TOXIC INGREDIENT
KNOWN TO US.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:REAGENT ALCOHOL, R8382
CAGE:21076
CAGE:21076
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ALCOHOL; (ETHANOL). LD50:(ORAL,RAT) 7060 MG/KG.
CAS:64-17-5
RTECS #:KQ6300000
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ingred Name:METHANOL (SARA 313) (CERCLA)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 5%
OSHA PEL:200 PPM, S
ACGIH TLV:200 PPM;250 STEL, S
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPYL ALCOHOL (SARA 313)
CAS:67-63-0
RTECS #:NT8050000
OSHA PEL:400 PPM
ACGIH TLV:400 PPM;500 STEL
Ingred Name:SUPDAT:MORTALITY, OTHER MEASURES OF FERTILITY); EFTS ON
EMBRYO/FETUS (EXTRA EMBRYONIC STRUCTURES, CYTOLOGICAL (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:CHANGES, FETOTOXICITY, FETAL DEATH, OTHER EFTS TO
EMBRYO/FETUS); SPECIFIC DEVEL ABNORMS (EYE, EAR, (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 7:CRANIOFACIAL, MUSCULOSKELETAL SYS, RESP SYS); EFTS ON
NEWBORN (GROWTH STATISTICS); TUMORIGENIC (EQUIVOCAL (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:TUMORIGENIC AGENT BY RTECS CRITERIA).
RTECS #:9999999ZZ
Ingred Name:EYE PROT:& FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:MAY BE FATAL IF INHALED,
SWALLOWED/ABSORBED THRU SKIN. VAP/FATAL IS IRRIT TO EYES, MUC MEMBS
& UPPER RESP TRACT. CAUSES SKIN IRRIT. CAN CAUSE CNS DEPRESS. EXPOS
CAN CAUSE: DMG TO EYES. NAUS, DIZ Z & HDCH. CHRONIC:DMG TO LIVER,
HEART &KIDNEYS. TARGET ORGAN(S):NERVES, EYES, LIVER, KIDNEYS.
WARNING:(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:CONTAINS METHANOL. MAY BE FATAL/CAUSE
BLINDNESS IF SWALLOWED. CANNOT BE MADE NONPOISONOUS. TARGET ORGAN
DATA:BEHAVIORAL (SLEEP, CHANGE IN MOTOR ACTIVITY, ATAXIA,
ANTIPSYCHOTIC, HDCH, CHANGE I N PSYCHOPHYSIOLOGICAL TESTS); LUNGS,
THORAX/RESP (CHRONIC PULM EDEMA/CONGESTION, DYSPNAE, OTHER
CHANGES); GI (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:IMMED FLUSH W/COPIOUS AMTS OF WATER FOR AT LST 15 MINS.
ASSURE ADEQ FLUSHING BY SEPARATING EYELIDS W/FINGERS. SKIN:IMMED
FLUSH W/COPIOUS AMTS OF WATER FOR AT LST 15 MINS WHILE REMOVING
CONTAM CLTH G & SHOES. WASH CONTAM CLTHG BEFORE REUSE. INHAL:REMOVE
TO FRESH AIR. IF NOT BRTHG GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE
OXYGEN. INGEST:WASH OUT MOUTH W/WATER PROVIDED PERS IS CONSCIOUS.
CALL MD.
===================== Fire Fighting Measures =====================
Flash Point:48.0F,8.9C
Lower Limits:3.3%
Upper Limits:24.5%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER OR APPROPRIATE
FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO COOL FIRE-EXPOSED CONTAINERS.
WARNING:FLAMMABLE LIQUID.
Unusual Fire/Explosion Hazard:VAPOR MAY TRAVEL CONSIDERABLE DISTANCE TO
SOURCE OF IGNITION & FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:SHUT OFF ALL SOURCES OF IGNIT. EVACUATE AREA.
ON SAND/VERMICULITE & PLACE IN CLSD CNTNRS FOR DISP. USE
NON-SPARKING TOOLS. VENT AREA & WASH SPILL SITE AFTER MATL PICKUP
IS COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT BREATHE VAPS. DO NOT GET IN
EYES, ON SKIN, ON CLTHG. AVOID PRLNG/RPTD EXPOS. POISON. IRRITANT.
KEEP CNTNR TIGHTLY CLSD. HYGROSCOPIC. TOXIC.
Other Precautions:KEEP AWAY FROM HEAT, SPKS, OPEN FLAME & SOURCES OF
IGNIT. HANDLE & STORE UNDER NITROGEN. STORE IN COOL, DRY PLACE.
HIGHLY FLAMM. MAY BE FATAL/CAUSE BLINDNESS IF SWALLOWED. VAP
HARMFUL. CANNOT BE MADE NON-POIS. CAUSES IRRIT. NO SMOKING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:WEAR SUITABLE PROTECTIVE CLOTHING. SAFETY
SHOWER & EYE BATH WHICH MEET ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
EFTS OF OVEREXP:ALTERATION IN GASTRIC SECRETION, HYPERMOTILITY, DIARR,
NAUS/VOMIT, OTHER CHANGES); LIVER (FATTY LIVER DEGENERATION,
TUMORS); BLOOD (OTHER CHANGES, LYMPHOMA INCL HODGKIN'S DISEASE);
PAT ERNAL EFTS (TESTES, EPIDIDYMIS, SPERM DUCT); EFTS ON FERTILITY
(FEMALE/MALE FERTILITY INDEX, POST-IMPLANTATION (ING 4)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:172F,78C
Melt/Freeze Pt:M.P/F.P Text:-202F,-130C
Vapor Pres:44.6 @ 20C
Vapor Density:1.59
Spec Gravity:0.785
Appearance and Odor:COLORLESS LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, PEROXIDES, ACIDS, ACID CHLORIDES, ACID ANHYDRIDES,
ALKALI METALS, AMMONIA.
Stability Condition to Avoid:MOISTURE.
Hazardous Decomposition Products:TOXIC FUMES OF: CARBON MONOXIDE,
CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED
W/AFTERBURNER & SCRUBBER BUT EXERT EXTRA CARE IN IGNITING AS THIS
MATERIAL IS HIGHLY FLAMMABLE. OBSERVE ALL FEDERAL, STATE & LOCAL
ENVIRONMENTAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:IMRON 5000 POLYURETHANE ENAMELS, 577H
Preparer's Name:T.R. LOUER
CAGE:0ERJ7
CAGE:0ERJ7
CAGE:18873
============= Composition/Information on Ingredients =============
Ingred Name:ACRYLIC POLYMER B
CAS:42767-92-0
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACRYLIC POLYMER E
CAS:70942-12-0
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACETIC ACID, BUTYL ESTER; (BUTYL ACETATE) (CERCLA). VP:8 @
20C.
CAS:123-86-4
RTECS #:AF7350000
OSHA PEL:150 PPM
ACGIH TLV:150 PPM;200 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETIC ACID, ETHYL ESTER; (ETHYL ACETATE) (CERCLA). VP:76
@ 20C.
CAS:141-78-6
RTECS #:AH5425000
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHANOL, 2-BUTOXY-, ACETATE; (ETHYLENE GLYCOL MONOBUTYL
ETHER ACETATE). VP:0.3 @ 20C.
CAS:112-07-2
RTECS #:KJ8925000
Other REC Limits:2 PPM, S (MFR)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:2-HEPTANONE; (METHYL AMYL KETONE). VP:2.2 @ 20C.
CAS:110-43-0
RTECS #:MJ5075000
OSHA PEL:100 PPM
ACGIH TLV:50 PPM
Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE) (MEK) (SARA 313)
(CERCLA). VP:71 @ 20C.
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 3%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM;300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ORGANOCLAY
CAS:68911-87-5
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ADIPIC ACID, ISOPHTHALIC, PENTAERYTHRITOL, PHTHAL ANHYD,
2,2DIMETH-1,3PROPAN POLYM, BENZOATE; (POLYESTER RESIN)
CAS:71010-58-7
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:XYLENE (SARA 313) (CERCLA). VP:25 @ 20C.
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 5%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM;150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:RESP PROT:ISOCYANATE SHOULD NOT USE/BE EXPOS TO THIS PROD.
DO NOT PERMIT ANYONE W/OUT PROT IN PAINTING AREA. (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:FOLLOW RESPIRATOR MFR'S DIRECTIONS FOR RESPIRATOR
USE.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP:DERM. ING 3:MAY CAUSE ABNORMAL LIVER FUNC.
HAS BEEN TOX TO FETUS IN LAB ANIMALS AT DOSES THAT (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:ARE TOX TO MOTHER: ING 4:PRLNG & RPTD HIGH EXPOS OF
LAB ANIMALS RSLTD IN SECONDARY ANEMIA W/INCR IN WHITE(ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:BLOOD CELLS; FATTY DEGENERATION, CLOUDY SWELL &
EXCESS OF BLOOD IN VARIOUS ORGS. ING 5:CAN BE ABSORBED (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:THRU SKIN IN HARMFUL AMTS. MAY DESTROY RED BLOOD
CELLS. MAY CAUSE ABNORMAL FUNC. ING 6:INGEST STUDIES ON (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:LAB ANIMALS SHOWED THAT VERY HIGH ORAL DOSES CAUSED
INCR LIVER & KIDNEY WTS. INGS 7 & 10:HIGH CONC HAVE (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:HAVE CAUSED EMBRYOTOX EFTS IN LAB ANIMALS. ING 7:HAS
BEEN DEMONSTRATED TO POTENTIATE (I.E., SHORTEN, TIME(ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19:OF ONSET) PERIPHERAL NEUROPATHY CAUSED BY EITHER
N-HEXANE/METHYL N-BUTYL KETONE. MEK BY ITSELF HAS NOT (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20:BEEN DEMONSTRATED TO CAUSE PERIPHERAL NEUROPATHY.
LIQ SPLASHES IN EYE MAY RSLT IN CHEM BURNS. ING 10: (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21:RECURRENT OVEREXP MAY RSLT IN LIVER & KIDNEY INJURY.
CAN BE ABSORBED THRU SKIN IN HARMFUL AMTS. ANIMAL (ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22:STUDIES CLEARLY DEMONSTRATED DOSE-RELATED ADVERSE
EFTS ON THE CNS, HEMATOPOIETIC TISSUES, BLOOD, KIDNEYS (ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23:& LIVER, ASSOC W/ADMIN OF ETHYLENE GLYCOL MONOBUTYL
ETHER ACETATE (EGBEA). (EXTRACTED FROM DHHS (NIOSH) (ING 25)
RTECS #:9999999ZZ
Ingred Name:ING 24:PUBLICATION NO.90-118) .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGEST:GI DISTRESS. INHAL:MAY CAUSE
NOSE & THROAT IRRIT. RPTD & PRLNG OVEREXP TO SOLVS MAY LEAD TO PERM
BRAIN & NERV SYS DMG. EYE WATERING, HDCHS NAUS, DIZZ & LOSS OF
COORD ARE SIGNS THAT SOLV LEVELS ARE TOO HIGH. EXPOS TO
ISOCYANATES MAY CAUSE RESP SENSIT. THIS EFT MAY BE PERM. THIS EFT
MAY BE DELAYED(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:FOR SEVERAL HRS AFTER EXPOS. RPTD
OVEREXP TO ISOCYANATES MAY CAUSE DECR IN LUNG FUNC WHICH MAY BE
PERM. INDIVIDUALS W/BRTHG PROBS/PRIOR RXN TO ISOCYANATES MUST NOT
BE EXPOS TO VAPS/SPRAY MIST S OF THIS PROD. EYE CONT:MAY CAUSE
IRRIT/BURNING. SKIN CONT:RPTD/PRLNG LIQ CONT MAY CAUSE IRRIT
W/DISCOMFORT & (ING 14)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD & HAVE NAMES OF INGREDIENTS AVAILABLE.
INHAL:REMOVE TO FRESH AIR. IF BREATHING DIFFICULTY PERSISTS, OR
OCCURS LATER, CONSULT MD. EYES:IMMEDIATELY FLUSH W/PLENTY OF WATER
FOR AT LEAST 15 MINUTES; CALL MD. SKIN:WASH W/SOAP & WATER. IF
IRRITATION OCCURS, CONTACT MD.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:-73F,-58C
Lower Limits:0.9%
Upper Limits:23%
Extinguishing Media:WATER SPRAY, FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER FROM FOG NOZZLES MAY BE USED TO COOL CLOSED
CONTAINERS TO PREVENT PRESSURE BUILD UP.
Unusual Fire/Explosion Hazard:WHEN HEATED ABOVE FLASH POINT, EMITS
FLAMMABLE VAPORS WHICH, WHEN MIXED W/AIR, CAN BURN/BE EXPLO. FINE
MISTS/SPRAYS MAY BE FLAMM AT TEMPS BELOW FLASH POINT.
================== Accidental Release Measures ==================
Spill Release Procedures:DO NOT BREATHE VAPS. DO NOT GET IN EYES/ON
SKIN. WEAR A NIOSH APPRVD POS PRESS SUPPLIED AIR VAP/PARTICULATE
IGNIT. ABSORB W/INERT MATL. R EMOVE SOURCES OF IGNIT. ABSORB
W/INERT (SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:OSHA STORAGE:IB. DO NOT BREATHE
VAPORS/MISTS. OBSERVE LABEL PRECAUTIONS. KEEP AWAY FROM HEAT,
SPARKS & FLAME. CLOSE CONTAINER AFTER EACH USE.
Other Precautions:FLAMMABLE LIQUID. GROUND CONTAINERS WHEN POURING. DO
NOT STORE ABOVE 120F. DO NOT SAND, FLAME CUT, BRAZE OR WELD DRY
COATING W/OUT A NIOSH APPROVED RESPIRATOR OR APPROPRIATE
VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH APPRVD POS PRESS SUPPLIED AIR RESP
(TC-19C) WHILE MIXING ACTIVATOR W/ANY PAINT/CLEAR ENAMEL, DURING
APPLICATION & UNTIL ALL VAPS & SPRAY MISTS ARE EXHAUSTED.
INDIVIDUALS W/HISTORY OF LUNG /BRTHG PROBS/PRIOR RXN TO (ING 12)
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME & PATTERN TO KEEP
CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . COVERALLS ARE RECOMMENDED.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE EATING
OR SMOKING.
Supplemental Safety and Health
SPILL PROC:MATL. VENT AREA. POUR LIQ DECONTAMINATE SOLN OVER SPILL &
ALLOW TO SIT 10 MINS, MIN. TYPICAL DECONTAM SOLNS ARE:20%
SURFACTANTS (TERGITOL TMN 10); 80% WATER; 0-10% AMMONIA; 2-5%
DETERGENT;BALANCE WATER. THIS PROC CAN GENERATE PRESS. DO NOT
SEAL CNTNR. AFTER 48 HRS, CNTNR MAY BE SEALED & DISPOSED OF.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>135F,>57C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:0.96
Evaporation Rate & Reference:LESS THAN ETHER
Solubility in Water:MISCIBLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:26.8
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CO, CO*2, SMOKE, OXIDES OF HEAVY
METALS IN INGREDIENTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. INCINERATE ABSORBED MATERIAL I/A/W FEDERAL, STATE &
LOCAL REQUIREMENTS. DO NOT INCINERATE IN CLOSED CONTAINERS.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:44 FLUX CORED SOLDER
CAGE:75297
CAGE:75297
============= Composition/Information on Ingredients =============
Ingred Name:LEAD (SARA 313) (CERCLA)
CAS:7439-92-1
RTECS #:OF7525000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE 1910.1025
ACGIH TLV:0.15MG/M3 DUST; 9495
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9495
Ingred Name:SILVER (SARA 313) (CERCLA)
CAS:7440-22-4
RTECS #:VW3500000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.01 MG/M3
ACGIH TLV:0.1 MG/M3; 9495
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:BISMUTH
CAS:7440-69-9
RTECS #:EB2600000
Other REC Limits:NONE RECOMMENDED
Ingred Name:ANTIMONY (SARA 313) (CERCLA)
CAS:7440-36-0
RTECS #:CC4025000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.5 MG/M3
ACGIH TLV:0.5 MG (SB)/M3; 9495
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ROSIN
CAS:8050-09-7
Fraction by Wt: <3%
Other REC Limits:NONE RECOMMENDED
Ingred Name:FLUX IN CORE
Fraction by Wt: 1 - 3%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS NOT RELEVANT.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, KIDNEYS, CNS,
RESPIRATORY & GI TRACTS. ACUTE- FLUX/FUMES MAY CAUSE EYE & SKIN
IRRITATION. FLUX FUMES MAY CAUSE IRRITATION & DAMAGE OF MUCOUS
MEMBRANES & RESPIRATORY SYSTEM. INGESTI ON IS NOT LIKELY TO OCCUR.
CHRONIC- INGESTION OF LEAD CAN RESULT IN SYSTEMIC POISONING
AFFECTING KIDNEYS & CNS.
Explanation of Carcinogenicity:CONTAINS LEAD.
Effects of Overexposure:IRRITATION, DIZZINESS, WATERY EYES, HEADACHE,
NAUSEA, BREATHING DIFFICULTY, COUGHING, CHEST PAINS, FEVER, BODY
ACHE, CHILLS. ARC RAYS CAN INJURE EYES & BURN SKIN. ELECTRIC SHOCK
CAN KILL. IR RADIATION CAN INJURE EYES.
Medical Cond Aggravated by Exposure:PERSONS WITH IMPAIRED PULMONARY
FUNCTION, AIRWAY DISEASES AND CONDITIONS SUCH AS ASTHMA, EMPHYSEMA,
CHRONIC BRONCHITIS, ETC... CAN BE AGGRAVATED BY THE EXPOSURE.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. EMPLOY FIRST AID
TECHNIQUE RECOMMENDED BY RED CROSS. IF BREATHING IS DIFFICULT,
PROVIDE OXYGEN AND CALL PHYSICIAN. PROVIDE CPR IF NEEDED. FOR
ELECTRIC SHOCK, DISCONNECT POWER. FOR ARC BURNS, APPLYCOLD, CLEAN
COMPRESSES AND CALL A PHYSICIAN. INGESTION UNLIKELY.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:USE CHEMICAL OR SAND FOR MOLTEN METALS. COOL
FIRE-EXPOSED CONTAINERS WITH WATER SPRAY.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS WITH FULL
FACEPIECE OPERATED IN THE POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:FLUX IN CORED SOLDER MAY IGNITE WHEN THE
SOLDER MELTS IN A FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:MELTED SOLDER WILL SOLIDIFY ON COOLING AND CAN
BE SCRAPED UP. AVOID GENERATING DUSTS. USE CAUTION TO AVOID
BREATHING FUMES OR DUSTS.
Neutralizing Agent:NOT RELEVENT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM INCOMPATIBLE MATERIALS
AND SULFUR. DO NOT PLACE FLUX CORED SOLDER INTO A HOT SOLDER POT
BECAUSE THE FLUX MAY IGNITE.
Other Precautions:AVOID BREATHING OF FUMES. USE WITH ADEQUATE
VENTILATION. WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING AND
DRINKING. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED SUPPLIED AIR RESPIRATORY
PROTECTION OR RESPIRABLE FUME RESPIRATOR WHEN WELDING, BRAZING OR
SOLDERING IN CONFINED SPACE OR WHERE LOCAL EXHAUST OR VENTILATION
DOES NOT KEEP EXPOSURE B ELOW TLV.
Ventilation:USE GENERAL & LOCAL EXHAUST AT FLAME TO KEEP FUMES AND
GASES BELOW TLV'S IN THE WORKER'S BREATHING ZONE & GENERAL AREA.
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER, HEAD, HAND
& BODY PROTECTION TO PREVENT INJURY FROM RADIATION, SPARKS &
ELECTRIC SHOCK.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NOT RELEVENT
Spec Gravity:>1
Viscosity:NOT RELEVANT
Evaporation Rate & Reference:NOT RELEVENT
Solubility in Water:INSOLUBLE
Appearance and Odor:SILVER-GRAY METAL IN WIRE, RIBBON OR PREFORMED
SHAPES WITH A CORE OF FLUX
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, LEAD
OXIDE FUMES, ALIPHATIC ALDEHYDES, ACIDS AND TERPENES MAY BE FORMED.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. KEEP PERSONNEL AWAY. DISCARD ANY PRODUCT, RESIDUE,
DISPOSABLE CONTAINER OR LINER IN AN ENVIRONMENTALLY ACCEPTABLE
MANNER, IN FULL COMPLIANCE W ITH LOCAL, STATE AND FEDERAL
REGULATIONS. RECLAIM.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BIURET SOLUTION (AQ)
Preparer's Name:R.M. CARLSON
CAGE:0X108
CAGE:0X108
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE (CERCLA)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:POTASSIUM SODIUM TARTRATE
CAS:304-59-6
Fraction by Wt: 0.60%
Other REC Limits:NONE RECOMMENDED
Ingred Name:CUPRIC SULFATE, PENTAHYDRATE
CAS:7758-99-8
RTECS #:GL8900000
Fraction by Wt: 0.15%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CORROSIVE SOLUTION. ACUTE: IRRITATION
AND PAIN TO SKIN, EYES, LUNGS, MUCOUS MEMBRANES AND GI TRACT.
CHRONIC: DERMATITIS.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN BY IARC, NTP OR OSHA.
Effects of Overexposure:IRRITATION, PAIN TO SKIN, EYES, LUNGS, MUCOUS
MEMBRANES, GI TRACT.
Medical Cond Aggravated by Exposure:PERSONS WITH PREEXISTING SKIN
DISORDERS MAY BE MORE SUSCEPTIBLE.
======================= First Aid Measures =======================
First Aid:EYES-FLUSH WITH WATER FOR 15 MINUTES, LIFT LIDS. GET
IMMEDIATE MEDICAL ATTENTION. SKIN-WASH WITH SOAP & WATER. GET
MEDICAL ATTENTION IF SYMPTOMS PERSIST. INHALED-REMOVE TO FRESH AIR.
RESTORE BREATHING AS NEEDED. GET MEDICAL ATTENTION. INGESTED-DO
NOT INDUCE VOMITING! IF CONSCIOUS, DRINK CITRUS JUICES. SEEK
IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NA
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND
FULL FACE-PIECE POSITIVE-PRESSURE SELF-CONTAINED BREATHING
APPARATUS.
Unusual Fire/Explosion Hazard:NOT CONSIDERED TO BE A FIRE/EXPLOSION
HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN-UP PERSONNEL REQUIRE PROTECTIVE
EQUIPMENT & RESPIRATORY PROTECTION. SMALL SPILLS CAN BE DILUTED
W/LARGE QUANTITIES OF WATER & NEUTRALIZED WITH DILUTE ACETIC ACID.
CAUTION! FLLOR & OTHER SURFACES MAY BE SLIPPERY. DO NOT FLUSH TO
SURFACE WATERS.
Neutralizing Agent:DILUTE ACETIC ACID.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:LOCAL/MECHANICAL (GENERAL).
Other Protective Equipment:LAB COAT & APRON. DLA-HMIS: EYE WASH STATION
& SAFETY SHOWER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING, DRINKING OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
MSDS PRESENTED BY CAGE 0X801 FOR CONTRACT NUMBER MDA414-98-P3046.
================== Physical/Chemical Properties ==================
HCC:C2
Boiling Pt:B.P. Text:NA
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:>1
Evaporation Rate & Reference:NA
Solubility in Water:COMPLETE, 100%
Appearance and Odor:CLEAR BLUE SOLUTION; NO ODOR.
Percent Volatiles by Volume:NA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A RCRA-APPROVED WASTE FACILITY OR
SEWER THE NEUTRALIZED SLURRY WITH EXCESS WATER IN LOCAL ORDANCES
ALLOW.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:6220 GLID-THANE II ACRYLIC COATING
CAGE:EO698
CAGE:01PD6
CAGE:EO698
============= Composition/Information on Ingredients =============
Ingred Name:ACETIC ACID, C6-8-BRANCHED ALKYL ESTERS, C3-8-BRANCHED
ALKYL ESTERS ACETIC ACID
CAS:90438-79-2
Fraction by Wt: 70-80%
Ingred Name:DIETHYLENE GLYCOL BUTYL ETHER ACETATE, ETHANOL, 2-
(2-BUTOXYETHOXY), BUTYL CARBITOL ACETATE
CAS:124-17-4
RTECS #:KJ9275000
Fraction by Wt: 20-30%
Ingred Name:VOLATILE ORGANIC CONTENT: 7.44 WT/GAL; 894.11 G/L
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION TO RESPIRATORY
TRACT/MUCOUS MEMBRANES/CNS DEPRESSION. ANESTHETIC. MAY CAUSE
BRONCHITIS, PULMONARY EDEMA/RESPIRATORY FAILURE. SKIN:
IRRITATION/DERMATITIS/ABSORPTION. EYES: IRRITA TION/CONJUNCTIVITIS.
INGESTION: LUNG INFLAMMATION. DAMAGE DUE TO ASPIRATION. MAY CAUSE
LIVER/KIDNEY DAMAGE. BURNS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION/LOSS OF
APPETITE/FATIGUE/DROWSINESS/DIZZINESS/LIGHTHEADEDNESS/HEADACHE/UNCO
ORDINATION/NAUSEA/VOMITING/DIARRHEA/CHEST
PAIN/COUGHING/INTOXICATION/TIGHTNESS OF CHEST/NARCOSIS/DIFFICULTY
BREATH ING/ASPHYXIATION/DEFATTING/BLISTERING/BURNS/ABDOMINAL
PAIN/TEARING/INFLAMMATION/BLURRED VISION/GI DISTURBANCES/REDNESS.
Medical Cond Aggravated by Exposure:EYE, SKIN, RESPIRATORY DISORDERS,
ASTHMA-LIKE CONDITIONS, KIDNEY/LIVER DISORDERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE/SUPPORT CONTINUED
BREATHING. HAVE TRAINED PERSON GIVE OXYGEN. SKIN: FLUSH W/WATER.
WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH IMMEDIATELY W/LARGE
AMOUNTS OF W ATER FOR 15 MINS. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:153F
Extinguishing Media:DRY CHEMICAL, FOAM, WATER FOG, CO2
Fire Fighting Procedures:WATER MAY BE USED TO COOL & PROTECT EXPOSED
CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT/FIRE. VAPORS MAY IGNITE EXPLOSIVELY AT
AMBIENT TEMPS. MAY EMIT TOXIC GASES UNDER FIRE CONDITIONS.(SUP
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. VENTILATE
W/EXPLOSION PROOF EQUIPMENT. COLLECT W/ABSORBENT. USE NON-SPARKING
TOOLS. PLACE COLLECTED MATERIAL IN PROPER CONTAINER. LARGE: SHUT
OFF LEAK SAFELY. DIKE/CONTAIN. PUMP TO STORAGE/SALVAGE VESSELS.
(SEE SUPP)
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 100F. KEEP AWAY FROM HEAT,
SPARKS, OPEN FLAME. KEEP CONTAINERS TIGHTLY CLOSED & UPRIGHT WHEN
NOT IN USE. EMPTY CONTAINERS CONTAIN RESIDUES
Other Precautions:GROUND EQUIPMENT WHEN TRANSFERRING TO PREVENT
ACCUMULATION OF STATIC CHARGE. USE ONLY W/ADEQUATE VENTILATION.
DON'T TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN. AVOID CONTACT
W/SKIN, EYES & BREATHI NG OF VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE ONLY NIOSH/MSHA APPROVED RESPIRATORS
IAW/OSHA STANDARD 29CFR 1910.134.
Ventilation:PROVIDE DILUTION/LOCAL EXHAUST TO PREVENT BUILDUP OF
VAPORS. USE EXPLOSION PROOF EQUIPMENT. NON-SPARKING EQUIPMENT.
Other Protective Equipment:EYE WASH, SAFETY SHOWER, IMPERVIOUS
CLOTHING, APRON, BOOTS, FACESHIELD.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS THOROUGHLY AFTER HANDLING, BEFORE EATING/SMOKING.
Supplemental Safety and Health
FIRE HAZ CONT'D: VAPORS ARE >AIR & MAY TRAVEL LONG DISTANCES TO AN
IGNITION SOURCE & FLASHBACK. VAPORS CAN FORM EXPLOSIVE MIXTURES IN
AIR AT ELEVATED TEMPS. INCOMPATIBLES: SURFACE ACTIVE MATERIALS/MAG
NESIUM/MINERAL ACIDS/SODIUM/POTASSIUM. SPILLS: KEEP SALVAGEABLE
MATERIAL & RINSE WATER OUT OF SEWERS/WATER COURSES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:349-482F
Appearance and Odor:STANDARD SOLVENT
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS/ACIDS/BASES/AMINES/ALKALIS
WATER/ALUMINUM/ZINC/PEROXIDES/NITRIC ACID/ALCOHOLS/METAL
COMPOUNDS/CAUSTICS. (SUPP)
Stability Condition to Avoid:ELEVATED TEMPS, SPARKS, OPEN FLAME & OTHER
IGNITION SOURCES, MOISTURE
Hazardous Decomposition Products:CO/CO2/NITROGEN OXIDES/HYDROGEN
CYANIDE/OXYGEN/ISOCYANATE/MONOAZO COMPOUNDS/AROMATIC AMINES/3,3
DICHLOROBENZIDINE
==================== Disposal Considerations ====================
Waste Disposal Methods:AVOID DISCHARGE TO NATURAL WATERS. DISPOSE OF IN
ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PREMIUM BLUE DIESEL ENGINE OIL, 3822214
CAGE:IO643
CAGE:IO643
CAGE:15434
============= Composition/Information on Ingredients =============
Ingred Name:SUPDAT:ANIMALS, TESTICLES FAILED TO MATURE NORMALLY DURING
28 DAY TEST PERIOD. IT IS POSS THAT CALCIUM PHENATE (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:INTERFERED W/MATURING PROCESS RATHER THAN CAUSING
DIRECT TESTICULAR EFT. TESTS W/FEEDING OF SIMILAR MATL (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:SHOWED NO TESTICULAR EFT IN MATURE RATS. DURING USE
IN ENGINES, CONTAM OF OIL W/LOW LEVEL CANCER-CAUSING (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:COMBUST PRODS OCCURS. USED MOTOR OILS HAVE BEEN
SHOWN TO CAUSE SKIN CANCER IN MICE FOLLOWING RPTD (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:APPLICATION & CONTINUOUS EXPOS. BRIEF/INTERMITTENT
SKIN CONT W/USED OIL IS NOT EXPECTED TO HAVE SERIOUS (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:EFTS IN HUMANS IF OIL IS THORO REMOVED BY WASHING
W/SOAP & WATER.
RTECS #:9999999ZZ
Ingred Name:VENT:MAY BE NEEDED.
RTECS #:9999999ZZ
Ingred Name:HYDROCARBON OIL; (HYDROCARBON BASE OILS)
Fraction by Wt: 77-82%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ADDITIVE PACKAGE (CONTAINING INGREDIENTS 3 - 7)
RTECS #:9999999ZZ
Fraction by Wt: 18-23%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PHOSPHORODITHIOIC ACID, ZINC SALT; (ZINC DITHIOPHOSPHATE
(ZDDP))
CAS:19210-06-1
RTECS #:TE4800000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CALCIUM PHENATE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VISCOSITY BUILDER; (VISCOSITY IMPROVER)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:INHIBITORS
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DISPERSANTS (IN LUBRICATING BASE OIL)
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:BRTHG MINERAL OIL MISTS ABOVE
EXPOS STD CAN CAUSE RESP IRRIT/DISCOMFORT. SKIN:EXPECTED TO CAUSE
NO MORE THAN MINOR IRRIT FOLLOWING PRLNG/FREQUENTLY RPTD CONT.
EYE:EXPECTED TO CAUSE NO MORE THANMINOR IRRIT. ZDDP HAS RECENTLY
BEEN TESTED BY RPTD APPLICATN TO SKIN OF MALE RABBITS. SEV SKIN
IRRIT, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:WT LOSS/FAILURE OF ANIMALS TO GAIN WT
& ADVERSE TESTICULAR EFTS, PRIMARILY UNDERDEVELOPED TESTICLES, WERE
SEEN. IT IS NOT YET CLEAR WHETHER TESTICULAR EFTS WERE DUE TO TOX
OF ZDDP/ TO SEV STR ESS PLACED ON ANIMALS AS RSLT OF EXTENSIVE SKIN
IRRIT. HOWEVER, STUDIES HAVE FOUND SIMILAR TESTICULAR EFTS WHEN
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR IF RESP DISCOMFORT/IRRIT OCCURS.
SEE MD IF DISCOMFORT/IRRIT CONTINUES. SKIN:WASH THORO W/SOAP &
WATER. REMOVE & LAUNDER CONTAM CLTHG BEFORE RE-USE. EYES: IMMED
FLUSH W/PLENTY OF WATER FOR AT LST 15 MINS. SEE MD IFIRRIT
CONTINUES. INGEST:DO NOT INDUCE VOMIT DUE TO RISK OF ASPIR OF LIQ
INTO LUNGS WHICH MAY LEAD TO CHEM PNEUM. OBTAIN MED ATTN IMMED.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>390F,>199C
Lower Limits:0.9%
Upper Limits:7%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM OR WATER SPRAY
(FOG).
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:DO NOT WELD, HEAT/DRILL CNTNR. RESIDUE
MAY IGNITE W/EXPLO VIOLENCE IF HEATED SUFFICIENTLY. CAUT:DO NOT USE
PRESS TO EMPTY DRUM/EXPLO MAY RSLT. SEE ALSO,(SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP SPILLS AS SOON AS POSS, OBSERVING
PRECS IN SPECIAL PROT INFO. ABSORB LG SPILLS W/ABSORB CLAY,
DIATOMACEOUS EARTH/OTHER SUITABLE MATL. THIS MATL IS NOT EXPECTED
TO PRESENT ANY ENVIRON PROBS OT HER THAN THOSE ASSOC W/OIL SPILLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, WELL VENTILATED
AREA. KEEP AWAY FROM HEAT, SPKS/OPEN FLAMES. KEEP CNTNR CLSD WHEN
NOT IN USE.
Other Precautions:MINIMIZE ALL SKIN CONT. PROPERLY DISPOSE OF
CONTAMINATED LEATHER ARTICLES, INCLUDING SHOES, THAT CANNOT BE
DECONTAMINATED. MFR STRONGLY RECS THAT PRECS OUTLINED IN MSDS BE
FOLLOWED TO MINIMIZE CONTACT W/THIS PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL RESPIRATORY PROTECTION NORMALLY
REQUIRED. HOWEVER, IF OPERATING CONDITIONS CREATE HIGH AIRBORNE
CONCENTRATIONS, USE OF A NIOSH/MSHA APPROVED RESPIRATOR IS
RECOMMENDED.
Ventilation:NO SPECIAL VENT USUALLY NEC. HOWEVER, IF OPERATING CNDTNS
CREATE HIGH AIRBORNE CONCS OF THIS MATL, SPECIAL VENT (ING 14)
Other Protective Equipment:AVOID PRLNG/FREQUENT SKIN CONTACT W/THIS
MATERIAL. SKIN CONT CAN BE MINIMIZED BY WEARING IMPERVIOUS PROT
CLOTHING.
Work Hygienic Practices:WASH THORO BEFORE EATING, DRINKING,
SMOKING/USING TOILET FACILITIES. REMOVE & LAUNDER CONTAM CLTHG
BEFORE RE-USE.
Supplemental Safety and Health
EXPLO HAZ:HAZ DECOMP PRODS. HAZ DECOMP PROD: COMBUST CAN PRDCE CARBON
MONOXIDE. EFTS OF OVEREXP:SKIN DMG & RESULTING STRESS ARE PRDCD BY
APPLICATION OF SIMPLE NON-ZDDP CAUSTIC MATL. IN RECENT RABBIT S
TUDY, HIGH DOSES OF CALCIUM PHENATE, SIMILAR TO ONE IN THIS PROD,
WERE APPLIED DAILY TO SKIN. IN THESE VERY YOUNG (ING 8
================== Physical/Chemical Properties ==================
HCC:V6
Spec Gravity:0.884 (H2O=1)
pH:7-7.5
Solubility in Water:INSOLUBLE
Appearance and Odor:DARK BROWN LIQUID; TYPICALLY OILY ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY REACT W/STRONG OXIDIZING MATERIALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NORMAL COMBUST FORMS CARBON DIOXIDE &
WATER VAP & MAY PRDCE OXIDES OF SULFUR, NITROGEN & PHOSPHOROUS.
INCOMPLETE(SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . PLACE CONTAMINATED MATERIALS IN DISPOSABLE CONTAINERS
& BURY IN AN APPROVED DUMPING AREA.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DLM-2990-S-Q DL-AMPHETAMINE HC
CAGE:5Y748
CAGE:5Y748
============= Composition/Information on Ingredients =============
Ingred Name:PHENETHYLAMINE *95-1*
CAS:51-64-9
RTECS #:SH9100000
Ingred Name:METHANOL (METHYL ALCOHOL), COLUMBIAN SPIRITS *95-1*
CAS:67-56-1
RTECS #:PC1400000
Other REC Limits:200 PPM
OSHA PEL:260 MG/CUM
ACGIH TLV:262 MG/CUM (SKIN)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HIGHLY TOXIC SUBSTANCE. VERY TOXIC BY
INHALATION, IN CONTACT W/SKIN & IF SWALLOWED MAY BE FATAL IF
INHALED, SWALLOWED/ABSORBED. CNS STIMULATION. FATAL POISONING,
CEREBRAL HEMMORAGING, POSSIBLE TERATOG EN. REPEATED EXPOSURE CAN
LEAD TO ADDICTION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:GI DISTURBANCES, CONVULSIONS, COMA, FEELING
UNWELL, BREATHING DIFFICULTY, IRRITATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. INGESTION: IF CONSCIOUS WASH
OUT MOUTH W/WATER. EYES: IMMEDIATELY FLUSH. SKIN: FLUSH W/LOTS OF
WATER FOR 15 MINS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, DRY CHEMICAL POWDER/APPROPRIATE FOAM.
Fire Fighting Procedures:WEAR SCBA & PROTECTIVE CLOTHING.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SCBA & PROTECTIVE CLOTHING. SWEEP UP,
PLACE IN BAG & HOLD FOR WASTE DISPOSAL. VENTILATE AREA & WASH SITE
AFTER MATERIAL PICKUP IS COMPLETE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE & KEEP
CONTAINER TIGHTLY CLOSED.
Other Precautions:AVOID CONTACT W/SKIN & EYES. DON'T BREATHE DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH/NIOSH APPROVED
RESPIRATOR.
Other Protective Equipment:WEAR SUITABLE PROTECTIVE CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Decomp Temp:Decomp Text:>572F
Solubility in Water:COMPLETE
Appearance and Odor:WHITE CRYSTALLINE PODER W/AMINE ODOR & A BITTER
TASTE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES
Hazardous Decomposition Products:TOXIC FUMES OF CO, CO2, NITROGEN
OXIDES, SULFUR OXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HAND CREAM
CAGE:FO693
CAGE:59943
CAGE:FO693
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL, WHITE; (WHITE MINERAL OIL) - (AS OIL MIST)
CAS:8042-47-5
RTECS #:PY8047000
Fraction by Wt: 5-10%
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:STEARIC ACID, 2-(2-HYDROXYETHOXY) ETHYL ESTER; (DIETHYLENE
GLYCOL STEARATE)
CAS:106-11-6
RTECS #:WI4025000
Fraction by Wt: 5-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: BALANCE
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MIST MAY CAUSE MILD
RESPIRATORY IRRITATION. SKIN: PROLONGED CONTACT MAY CAUSE MILD SKIN
IRRITATION IN SENSITIVE INDIVIDUALS. EYES: CONTACT MAY CAUSE
BURNING AND IRRITATION. INGESTION: MAY CAUSE NAUSEA.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INHAL: MOVE TO FRESH AIR. GET MEDICAL HELP IF IRRITATION
PERSISTS. SKIN: WASH AFFECTED AREA WITH LARGE AMOUNTS OF WATER. GET
MEDICAL HELP IF IRRITATION PERSISTS. EYES: IMMEDIATELY FLUSH EYES
WITH LARG E AMOUNT OF WATER FOR AT LEAST 15 MINUTES WHILE HOLDING
THE EYE LIDS OPEN. GET PROMPT MEDICAL ATTENTION. INGESTION: CONTACT
LOCAL POISON CONTROL CENTER OR MD IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING MATERIALS.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP WITH ABSORBENT MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:RECOMMEND STORAGE BETWEEN 40F (5C) AND
100F (37C).
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED. IF TLV IS EXCEEDED, OR
FOR SYMPTOMS OF OVEREXPOSURE, WEAR A NIOSH/MSHA APPROVED DUST/MIST
RESPIRATOR.
Ventilation:NOT NORMALLY REQUIRED. IF NEEDED, PROVIDE ADEQUATE GENERAL
DILUTION VENTILATION.
Other Protective Equipment:NONE.
Work Hygienic Practices:CLEAN UP ALL SPILLS IMMEDIATELY. PRACTICE GOOD
PERSONAL HYGIENE.
Supplemental Safety and Health
SPEC GRAV: 0.975-0.985 (H*2O=1). PH: 7.5-8.5. % VOLAT: <5 (MINUS
WATER). NOTE: SELECTION OF PERSONAL PROTECTIVE EQUIPMENT SHOULD BE
MADE BY MATERIAL USER BASED ON PARTICULAR PLANT CONDITIONS WHERE
MAT ERIAL IS TO BE USED TOGETHER WITH INFORMATION CONTAINED IN
MSDS.
================== Physical/Chemical Properties ==================
Spec Gravity:SUPDAT
pH:SUPDAT
Evaporation Rate & Reference:<1 (BUAC=1)
Solubility in Water:MODERATE
Appearance and Odor:VISCOUS, YELLOW LOTION WITH ALMOND ODOR.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE UNDER NORMAL USE CONDITIONS.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
NIIN: 01-388-5606
Product ID: PRIMER N 7649 (25 GM),21347
Cage: 05972
=======================================================
Contractor Summary
=======================================================
Cage: 05972
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: PRIMER,SEALING COMPOUND
Specification Number: MIL-S-22473
Unit of Issue: BT
Quantitative Expression: 20000000175OZ
UI Container Qty: 0
=======================================================
Ingredients
=======================================================
Cas: 67-64-1
RTECS #: AL3150000
% Wt: 75 - 80
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 1000 PPM
ACGIH TLV: 750PPM/1000STEL;9596
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 75-28-5
RTECS #: TZ4300000
% Wt: 20 - 25
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Cas: 149-57-5
RTECS #: MO7700000
% Wt: 0.1 - 1
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Cas: 22221-10-9
RTECS #: MO7708000
% Wt: 0.1 - 1
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Cas: 58823-74-8
% Wt: 0.1 - 1
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50 (ORAL, RAT) IS NOT KNOWN.
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: TARGET ORGANS:EYES, SKIN, CNS, RESPIRATORY & GI
TRACTS. ACUTE- NARCOTIC AT HIGH CONCENTRATIONS. INHALATION MAY CAUSE CNS
EFFECTS. MAY CAUSE IRRITATION OF EYES, SKIN & RESPIRATORY TRACT. MAY
CAUSE SKIN DEFATTING. HARMFUL IF INHALED/INGESTED. MODERATELY TOXIC BY
INGESTION. ASPIRATION HAZAZARD. CHRONIC- UNKNOWN.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: IRRITATION, HEADACHE, DIFFICULTY IN
BREATHING, NAUSEA, VOMITING, DEFATTING, DIZZINESS, LOSS OF COORDINATION,
FATIGUE, CONFUSION, DERMATITIS, BLURRED VISION, TEARING
Medical Cond Aggravated By Exposure: INDIVIDUALS WITH PRE-EXISTING DISEASES OF
THE EYE, SKIN, RESPIRATORY TRACT, CNS MAY HAVE INCREASED SUSCEPTIBILITY TO
THE TOXICITY OF EXCESSIVE EXPOSURES.
First Aid: GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH AIR.
PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15 MINUTES, HOLDING
EYELIDS OPEN. SKIN:WASH WITH SOAP & WATER. ORAL:DO NOT IN DUCE VOMITING.
IF CONSCIOUS, DRINK WATER. SEEK IMMEDIATE MEDICAL ATTENTION. IF SPONTANEOUS
VOMITING OCCURS, KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION OF VOMITUS INTO
LUNGS. KEEP INDIVIDUAL CALM.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: VENTILATE AREA. REMOVE IGNITION SOURCES. LEAKING
CONTAINERS SHOULD BE PLACED OUTDOORS, IN AN OPEN CONTAINER, AWAY FROM SOURCES
OF IGNITION. ALLOW PRESSURE TO DISSIPATE. ABSORB LIQUID WITH NON-FLAMMABL E
ABSORBENT AND PLACE IN CONTAINER FOR DISPOSAL.
Neutralizing Agent: NOT RELEVANT
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE AND
FEDERAL REGULATIONS. DO NOT PUNCTURE, INCINERATE SPRAY CANS EVEN AFTER USE.
DO NOT FLUSH INTO DRAINS. CONTRACT WITH APPROVED WASTE DISPOSAL FACILITY
CAPABLE OF HANDLING FLAMMABLE AEROSOLS.
Handling And Storage Precautions: STORE SPRAY CANS IN COOL, WELL VENTILATED
AREAS AWAY FROM SOURCES OF IGNITION, INCOMPATIBLES & SUNLIGHT. DO NOT
STORE ABOVE 120F.
Other Precautions: "EMPTY" CONTAINERS RETAIN RESIDUE AND MAY BE DANGEROUS.
FOLLOW ALL LABEL INSTRUCTIONS. AVOID REPEATED/PROLONGED SKIN CONTACT. KEEP
OUT OF REACH OF CHILDREN. DO NOT BREATHE VAPORS. DO NOT SPRAY TOWARD
FACE/HOT SURFACES. WASH AFTER HANDLING.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: FLAMMABL AEROSOL
Lower Limits: 1.8ISOBUTANE
Upper Limits: 13 ACETONE
Extinguishing Media: DRY CHEMICAL, CARBON DIOXIDE, FOAM. COOL FIRE-EXPOSED
CONTAINERS WITH WATER SPRAY.
Fire Fighting Procedures: WEAR FULL PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard: SPRAY CANS UNDER PRESSURE. EXTREMELY FLAMMABLE.
EXPLOSION HAZARD EXISTS WHEN SPRAY CANS HEATED. DO NOT ENTER SPRAY CAN
STORAGE AREA IF FIRE PRESENT.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF TLV IS EXCEEDED, WEAR NIOSH-APPROVED ORGANIC VAPOR
RESPIRATOR OR AIR-PURIFYING RESPIRATOR. IN EMERGENCY, WEAR A NIOSH-APPROVED
POSITIVE-PRESSURE SELF-CONTAINED BREATHING APPARATUS.
Ventilation: MECHANICAL (GENERAL AND/OR LOCAL EXHAUST, EXPLOSION-PROOF)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment: EYE WASH STATION & SAFETY SHOWERS SHOULD BE
AVAILABLE IN THE IMMEDIATE VICINITY OF ANY POTENTIAL EXPOSURE.
Work Hygienic Practices: OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING, DRINKING/SMOKING.
Supplemental Safety and Health: EXTREMELY FLAMMABLE. CONTENTS UNDER PRESSURE.
CONTAINS FLAMMABLE GAS SUCH AS PROPANE AND FLAMMABLE LIQUID. DO NOT USE IN
CONFINED AREA OR AREA WITH LITTLE AIR MOVEMENT. EMPLOY MEANS TO PREVENT VAPOR
B UILDUP.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: V3
NRC/State LIC No: NOT RELEVANT
Boiling Point: =56.1C, 133.F
M.P/F.P Text: UNKNOWN
Decomp Text: UNKNOWN
Vapor Pres: 172 @ 68F
Vapor Density: UNKNOWN
Spec Gravity: 0.791 BASE ONLY
VOC Grams/Liter: 787
Viscosity: NOT KNOWN
Evaporation Rate & Reference: UNKNOWN
Solubility in Water: MISCIBLE
Appearance and Odor: GREEN LIQUID - ACETONE ODOR
Percent Volatiles by Volume: 99.5
Corrosion Rate: UNKNOWN
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HIGH HEAT, OPEN FLAMES, DIRECT SUNLIGHT,
TEMPERATURES ABOVE 120F
Materials To Avoid: STRONG OXIDIZING AGENTS, PEROXIDES
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE, IRRITATING
ORGANIC VAPORS
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 132874
Product ID: PRIMER N 7649 (25 GM),21347
Review Date: 12/12/1996
Tech Entry NOS Shipping Nm: ISOBUTANE, ACETONE
Net Unit Weight: 0.1 LB
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: BT
Container QTY: 0
Additional Data: DOT (DOMESTIC GROUND TRANSPORT) PROPER SHIPPING NAME: CONSUMER
COMMODITY, ORM_D (PER MSDS). IATA PRO PER SHIPPING NAME, UN ID NUMBER PER
MSDS.
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: XXX
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: AIY
IMO Proper Shipping Name: AEROSOL DISPENSERS ?
IMO PSN Modifier: ,WITH A CAPACITY OF 1000 CUBIC CM OR LESS
IMDG Page Number: 9022
UN Number: 1950
UN Hazard Class: 9?
IMO Packaging Group: -
Subsidiary Risk Label: -
EMS Number: 2-13
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ALS
IATA UN ID Num: 1950
IATA Proper Shipping Name: AEROSOLS, FLAMMABLE
IATA PSN Modifier: (EACH NOT EXCEEDING 1 L CAPACITY)
IATA UN Class: 2.1
IATA Label: FLAMMABLE GAS
Packing Note Passenger: 203
Max Quant Pass: 75KG
Max Quant Cargo: 150KG
Packaging Note Cargo: 203
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ALR
AFI Symbols: *
AFI Proper Shipping Name: AEROSOLS, FLAMMABLE, N.O.S.
AFI PSN Modifier: (EACH NOT EXCEEDING 1L CAPACITY)
AFI Hazard Class: 2.1
AFI UN ID NUM: UN1950
Special Provisions: P4
Back Pack Reference: A6.3
=======================================================
HAZCOM Label
=======================================================
Product ID: PRIMER N 7649 (25 GM),21347
Cage: 05972
Company Name: LOCTITE CORPORATION
Street: 1001 TROUT BROOK CROSSING
Zipcode: 06067-3910
Label Required IND: Y
Date Of Label Review: 12/12/1996
Status Code: C
MFG Label NO: UNKNOWN
Label Date: 12/12/1996
Origination Code: F
Skin Protection IND: YES
Signal Word: DANGER
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: TARGET ORGANS:EYES, SKIN, CNS, RESPIRATORY & GI
TRACTS. ACUTE- NARCOTIC AT HIGH CONCENTRATIONS. INHALATION MAY CAUSE CNS
EFFECTS. MAY CAUSE IRRITATION OF EYES, SKIN & RESPIRATORY TRACT. HARMFUL
IF INH ALED/INGESTED. ASPIRATION HAZAZARD. CHRONIC- UNKNOWN. STORE IN COOL,
VENTILATED AREAS AWAY FROM SOURCES OF IGNITION, INCOMPATIBLES. ABSORB SPILL
WITH NON-FLAMMABLE ABSORBENT & PLACE IN CONTAINER FOR D ISPOSAL. FIRST
AID- GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH AIR.
PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15 MINUTES. HOLD
EYELIDS OPEN. SKIN:WASH WITH SOAP & WATE R. ORAL:DON'T INDUCE VOMITING.
CALL DOCTOR AT ONCE
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LATEX SATIN & GLOSS EXTERIOR FINISHES (SUPP
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA III). VP:0.1
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: <5%
OSHA PEL:50 PPM STEL, C
ACGIH TLV:50 PPM STEL, C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE; (CRISTOBALITE)
CAS:14464-46-1
RTECS #:VV7325000
Fraction by Wt: 1-2%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.05 MG/M3 RDUST9293
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 1-2%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:ZINC OXIDE. PEL:10 MG/M3 TDUST; 5 MG/M3 RDUST
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: 0-2%
OSHA PEL:15MG/M3 TDUST/5 FUME
ACGIH TLV:10MG/M3 TDUST; 9293
Ingred Name:SUPP DATA:DUST AT 250 MG/M3 DEVELOPED LUNG CANCER, HOWEVER,
SUCH EXPOSURE LEVELS ARE NOT ATTAINABLE IN THE WORKPLACE.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:ONLY DURING SANDING/ABRADING OF DRIED FILM. IF
NO SPECIFIC DUSTS ARE LISTED IN INGRED SECTION, THE (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:APPLIC LIMITS FOR NUISANCE DUSTS ARE ACGIH TLV
10MG/M3 (TDUST), OSHA PEL 15MG/M3 (TDUST), 5MG/M3 (RESP FRACTION).
RTECS #:9999999ZZ
Ingred Name:RESP PROT:APPROVED DUST/MIST RESP FOR DUST WHICH MAY BE
GENERATED FROM THIS PRODUCT, UNDERLYING PAINT OR THE ABRASIVE.
RTECS #:9999999ZZ
Ingred Name:VENT:LIMITS. REFER TO OSHA STANDARD 1910.94, 1910.107,
1910.108.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRIT OF EYES, SKIN & UPPER
RESP SYS. IN A CONFINED AREA, VAPS IN HIGH CONC MAY CAUSE HDCH,
NAUS OR DIZZ. REDNESS & ITCHING OR BURNING SENSATION MAY INDICATE
EYE OR EXCESSIVE SKIN EXPOS. CHRONI C: LONG TERM EXPOS TO HIGH
LEVELS OF SILICA DUST, WHICH CAN OCCUR ONLY WHEN SANDING/ABRADING
DRY (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-CRISTOBALITE: GROUP
2A (IARC);ANTICIPATED TO BE A CARCINOGEN(NTP).
Effects of Overexposure:HLTH HAZ:FILM, MAY CAUSE LUNG DAM (SILICOSIS) &
POSS CANCER. ETHYLENE GLYCOL IS CONSIDERED AN ANIMAL TERATOGEN. IT
HAS BEEN SHOWN TO CAUSE BIRTH DEFECTS IN RATS/MICE AT HIGH DOSES
WHEN GIVEN IN DRINKI NG WATER OR BY GAVAGE. THERE IS NO EVIDTO
INDICATE IT CAUSES BIRTH DEFECTS IN HUMANS. PRLNGD OVEREXPOS TO
(SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE BREATHING.
KEEP WARM & QUIET. SKIN:WASH AFFECTED AREA THOROUGHLY W/SOAP &
WATER. REMOVE CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE.
EYE:FLUSH W/LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINS.GET
MEDICAL ATTENTION. INGEST:GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>199F,>93C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL & ALCOHOL FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER SPRAY MAY BE INEFT. IF WATER IS USED, FOG NOZZ ARE PREF.
WATER MAY BE USED TO COOL CLSD (SUPP DATA)
Unusual Fire/Explosion Hazard:CLOSED CONTAINER MAY EXPLODE (DUE TO THE
BUILD-UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE &
REMOVE W/INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTRS CLSD WHEN NOT IN USE. USE
ONLY W/ADEQ VENT. AVOID BRTHG VAP/SPRAY MIST. AVOID CONT
W/SKIN/EYES. DO NOT TAKE INTERNALLY.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. TRANSFER ONLY TO
APPRVD CONTRS W/COMPLETE & APPROP LABELING. THIS COATING MAY
CONTAIN MATLS CLASSIFIED AS NUISANCE PARTICULATES (LISTED AS DUST
IN INGRED SECTION) WHICH MAY BE PRESENT AT HAZ LEVELS (ING 6)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIMITS BY VENT, WEAR A PROPERLY FITTED, NIOSH/MSHA APPRVD
ORG VAP/PARTICULATE RESP FOR PROT AGAINST MATLS IN INGRED SECTION.
WHEN SANDING/ABRADING D RIED FILM, WEAR A NIOSH/MSHA (ING 8)
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPTABLE IF EXPOS TO MATLS IN
INGRED SECTION IS MAINTAINED BELOW APPLIC EXPOS (ING 9)
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
MFRS TRADE NAME/PART NO:PROMAR SATIN TINT WHITE, B37 W 101. PH:9.3-9.8.
FIRE FIGHT PROC:CONTRS TO PVNT PRESS BUILD-UP & POSS
AUTOIGNITION/EXPLOS WHEN EXPOSED TO EXTREME HEAT. EFTS OF
OVEREXP:SOLV INGR EDS MAY CAUSE ADVERSE EFTS TO LIVER, URINARY &
BLOOD FORMING SYS. RATS EXPOSED TO TITANIUM DIOXIDE (ING 5)
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:1.1-1.4
pH:SUPDAT
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:52-75
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE & CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM LATEX FINISHES IS NOT HAZARDOUS.
INCINERATE IN APPROVED FACILITY. DO NOT INCINERATE CLOSED
CONTAINERS. DISPOSE OF I/A/W FEDERAL, STATE & LOCAL REGULATIONS
REGARDING POLLUTION.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:82 SATIN SHEEN
CAGE:01PD6
CAGE:01PD6
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, AMORPHOUS, PRECIPITATED AND GEL, SYNTHETIC
CRYSTALLINE-FREE SILICA GEL *96-2*
CAS:112926-00-8
RTECS #:VV7315000
Fraction by Wt: 1-5%
ACGIH TLV:10 MG/CUM
Ingred Name:STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 10-20%
Other REC Limits:525 MG/CUM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC, HIGH FLASH
AROMATIC NAPHTHA, C8&10 AROMATIC HYDROCARBON *96-2*
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 1-5%
Ingred Name:BENZENE (SUSPECTED HUMAN CARC BY ACGIH, IARC, ANIMAL
CARCINOGEN BY IARC, CARCINOGEN BY NTP - IARC GROUP 1) *96-2*
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: 0.01-.1%
Other REC Limits:16 MG/CUM
ACGIH TLV:0.3 MG/CUM (A2) IC
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED (C10-C15 SATURATED
HYDROCARBONS 97%, C10 AROMATICS 3%) *96-2*
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 10-20%
Other REC Limits:200 PPM EXXON
Ingred Name:NAPHTHA PETROLEUM, HEAVY ALKYLATE C9-C12 BOILING PT
302-428F *96-2*
CAS:64741-65-7
Fraction by Wt: 10-20%
Ingred Name:FATTY ACIDS, TALL-OIL, POLYMERS W/ETHYLENE GLYCOL,
GLYCEROL, ISOPHTHALIC ACID, PENTAERYTHRITOL & PROPYLENE GLYCOL
*96-2*
CAS:68333-62-0
Fraction by Wt: 20-30%
Ingred Name:SOYBEAN OIL, POLYMER W/PENTAERYTHRITOL, TDI & TUNG OIL
*96-2*
CAS:67989-28-0
Fraction by Wt: 20-30%
Ingred Name:COBALT (II) 2-ETHYLHEXANOATE, COBALT OCTOATE *96-2*
CAS:136-52-7
Fraction by Wt: 0.1-1%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY TRACT
IRRITATION, CNS DEPRESSION, LIVER/KIDNEY DAMAGE, PULMONARY EDEMA,
PNEUMOCONIOSIS, RESPIRATORY FAILURE, ASPHYXIATION, DEATH. SKIN:
IRRITATION, DERMATITIS, CNS DEPRESSION, DEATH. EYES: IRRITATION,
CONJUNCTIVITIS. INGESTION: LUNG DAMAGE DUE TO ASPIRATION OF
MATERIAL.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:IRRITATION, APPETITE LOSS, FATIGUE, DROWSINESS,
DIZZINESS/LIGHTHEADEDNESS, HEADACHE, UNCOORDINATION, NAUSEA,
VOMITING, BLURRED VISION, COUGHING, SPEECH DIFFICULTY, CONFUSION,
ANESTHETIC, NARCOSIS, BRE ATHING DIFFICULT/TREMORS/CONVULSIONS/LOSS
OF CONSCIOUSNESS/DEFATTING/BLISTERING/TEARING OF EYES/ABDOMINAL
PAIN/CYANOSIS.
Medical Cond Aggravated by Exposure:EYE, SKIN, RESPIRATORY DISORDERS,
LUNG DISORDERS, ASTHMA-LIKE CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE & SUPPORT BREATHING.
HAVE TRAINED PERSON GIVE OXYGEN IF NECESSARY. SKIN: FLUSH W/WATER,
THEN WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH W/LARGE AMOUNTS OF
WAT ER FOR 15 MINS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:103F
Extinguishing Media:DRY CHEMICAL/FOAM WATER FOG, CO2.
Fire Fighting Procedures:COOL CONTAINERS W/WATER. WEAR FULL PROTECTIVE
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS EXPLODE WHEN EXPOSED TO
EXTREME HEAT/FIRE. VAPORS IGNITE AT AMBIENT TEMP & CAN FORM
EXPLOSIVE MIXTURES IN AIR AT ELEVATED TEMP. (SEE SUPP)
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. VENTILATE
W/EXPLOSION-PROOF EQUIPMENT. COLLECT W/ABSORBENT MATERIALS. USE
NON-SPARKING TOOLS. EVACUATE. USE PROPER CONTAINER. WEAR PROTECTIVE
EQUIPMENT. LARGE: SHUT OFF, SA FELY. DIKE & CONTAIN. (SEE SUPP)
======================Handling and Storage ======================
Handling and Storage Precautions:STORE <80F. KEEP AWAY FROM HEAT, OTHER
IGNITION SOURCES & DIRECT SUNLIGHT. USE W/ADEQUATE VENTILATION.
AVOID INHALABLE PARTICLES/SPRAYING/ABRADING.
Other Precautions:KEEP CONTAINERS TIGHTLY CLOSED & UPRIGHT WHEN NOT IN
USE. AVOID INHALATION. EMPTY CONTAINERS MAY CONTAIN HAZARDOUS
RESIDUES. GROUND WHEN TRANSFERRING. AVOID CONTACT W/SKIN & EYES.
DON'T TAKE INTERNALL Y. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE RESPIRATORY PROTECTION IS REQUIRED, USE
ONLY NIOSH/MSHA APPROVED RESPIRATORS IAW/OSHA.
Ventilation:DILUTION/LOCAL EXHAUST VENTILATION. USE EXPLOSION-PROOF &
NON-SPARKING EQUIPMENT.
Other Protective Equipment:EYEWASH, SAFETY SHOWER, IMPERVIOUS CLOTHING,
FACE SHIELD, APRON, BOOTS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:155-554F
VOC Pounds/Gallon:485
Appearance and Odor:SATIN SHEEN
Percent Volatiles by Volume:61.81
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, BASES, AMINES, HYPOCHLORITES, PEROXIDES, NITRIC ACID,
METAL SALTS, METAL CHLORIDES, MINERAL ACIDS.
Stability Condition to Avoid:SUNLIGHT, ELEVATED TEMP, SPARKS, OPEN
FLAME & OTHER IGNITION SOURCES.
Hazardous Decomposition Products:CO, CO2, ACRID FUMES, OXIDES OF
SULFUR, OXIDES OF PHOSPHORUS, ALDEHYDES, TOXIC GASES, STYRENE, ZINC
OXIDE, SMOKE & SOOT.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:2087P, EVR-WHITE SHEET GOODS ADHESIVE
Preparer's Name:MEL NICHOLS
CAGE:HO551
CAGE:0LE45
CAGE:HO551
============= Composition/Information on Ingredients =============
Ingred Name:NON HAZARDOUS INGREDIENT
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: NONE KNOWN. EYES: MAY CAUSE
MILD IRRITATION. SKIN: NONE KNOWN. INGEST: NONE KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NONE KNOWN.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN: WASH
WITH SOAP AND WATER. INHAL: REMOVE TO FRESH AIR IF NEEDED. INGEST:
CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NON-FLAMMABLE. USE MEDIA SUITABLE FOR SURROUNDING
FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT MATERIAL TO COLLECT AND CONTAIN
FOR SALVAGE OR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT PUNCTURE. KEEP OUT OF REACH OF
CHILDREN. FREEZE - THAW STABLE AT 10F.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED. NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
% VOLAT: 40-50 (WT).
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:SAME/WATER
Vapor Density:SAME/WATER
Evaporation Rate & Reference:SAME AS WATER
Appearance and Odor:OFF WHITE WITH NO ODOR.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:ABIDE BY ALL STATE, FEDERAL AND LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:STA-STUCK CONST ADHESIVE, SS1000
Preparer's Name:REGINE LECLERC
CAGE:CBRND
CAGE:CBRND
============= Composition/Information on Ingredients =============
Ingred Name:HEXANE.VP: 140@68F
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: 10-20%
OSHA PEL:500 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TOLUENE. VP: 24@68F
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 5-15%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: HIGH VAP CONC ARE IRRITATING TO
EYES & RESP TRACT. THEY MAY CAUSE HDCH, DIZZ/ANESTH & MAY HAVE
OTHER CNS EFTS. CHRONIC: RPTS HAVE ASSOC RPTD & PRLNGD OCCUP
OVEREXP TO SOLV W/PERM BRAIN DAM. INT ENTIONAL MISUSE BY DELIB CONC
& INHALING THIS PROD MAY BE HARMFUL/FATAL. INHAL: BRTHG HIGH CONC
OF (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: VAPS/MIST MAY CAUSE IRRIT OF NOSE &
THROAT & SIGNS OF NERV SYS DEPRESS(E.G., DROW, DIZZ, & LOSS OF
COORD). SKIN/EYE: MATL MAY CAUSE IRRIT. PRLNGD/RPTD EXPOS TO MATL
MAY CAUSE RED, BURN, & DR Y/CRACK OF SKIN. PERSONS
W/PRE-EXISTINGSKIN DISORDERS MAY BE MORE SUSCEPTIBLE TO EFTS. SKIN
ABSORP: NO (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LG AMTS OF WATER FOR @ LST 15 MIN, LIFT LIDS
OCCAS, & GET MED ATTN. SKIN: WASH EXPOS AREA W/SOAP/WATER, REMOVE
CONTAMD CLTHG, & LAUNDER CONTAMD CLTHG BEEFORE RE-USE. INGEST: DO
NOT INDUC E VOMIT, KEEP WARM, QUIET, & GET MED ATTN(ASPIR OF MATL
INTO LUNGS DUE TO VOMIT CAN CAUSE CHEM PNEUM WHICH CAN BE FATAL).
INHAL: REMOVE TO FRESH AIR & IF BRTHG IS DFCLT, ADMINISTER OXYGEN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:0F,-18C
Lower Limits:1%
Upper Limits:8%
Extinguishing Media:FOAM, ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL,
WATER FOG.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP. USE
WATER SPRAY TO COOL CONTAINERS. AVOID SPREADING BURNING LIQ W/WATER
USED FOR COOLING PURPOSES.
Unusual Fire/Explosion Hazard:VAPORS MAY TRAVEL TO SOURCE OF IGNITION &
FLASH BACK. DO NOT USE JET STREAM OF WATER TO PREVENT SPREADING
FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:STAY UPWIND & AWAY FROM SPILL. KEEP ALL
SOURCES OF IGNITION FROM SPILL. IF SPILL IS INDOORS, VENT AREA OF
SPILL. KEEP OUT OF DRAINS. USE SAND/OTHER INERT MATERIAL TO DAM &
CONTAIN MATERIAL. DO NOT FLU SH WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTRS TIGHTLY CLSD. KEEP CONTRS
COOL, DRY & AWAY FROM SOURCES OF IGNIT. USE & STORE PROD W/ADEQ
VENT.
Other Precautions:ALL EMPTY CONTAINERS SHOULD BE DISPOSED OF IN
ENVIRONMENTALLY SAFE MANNER & I/A/W GOVERNMENTAL REGULATIONS.
FOLLOW THE LABEL INSTRUCTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF WORKPLACE EXPOS LIM OF PROD IS EXCEED, A
NIOSH/MSHA APPRVD AIR SUPPLIED RESP IS ADVISED IN ABSENCE OF PROPER
ENVIRONMENTAL CONTROL. ENGINEERING/ADMINISTRATIVE CONTROLS SHOULD
BE IMPLEMENTED TO REDU CE EXPOSURE.
Ventilation:PROVIDE SUFFICIENT MECHANICAL(GEN &/OR LOC EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING & BOOTS.
Work Hygienic Practices:FOLLOW THE LABEL INSTRUCTIONS.
Supplemental Safety and Health
EFTS OF OVEREXP: HARMFUL EFTS HAVE BEEN DEMONSTRATED IN SKIN ABSORP
STUDIES. NOTE: TOLUENE CAS#108-88-3 APPEARS ON NAVY LIST OF OCCUP
REPROD HAZ. SEEK CONSULTATION FROM APPROP HLTH PROFESSIONALS CONCE
RNING LATEST HAZ LIST INFO & SAFE HANDLING & EXPOSURE RECOM .
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:149F,65C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:1.2(H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TAN MASTIC-PETROLEUM DISTILLATE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT & FLAMES(IGNITION
SOURCES).
Hazardous Decomposition Products:MAY FORM TOXIC MATERIALS: CARBON
DIOXIDE, CARBON MONOXIDE, VARIOUS HYDROCARBONS, ETC.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF PRODUCT I/A/W LOCAL, COUNTY, STATE, &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:190 0463,EA-5 FIRST DEVELOPER, PART B
Kit Part:Y
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 55-60%
Ingred Name:SODIUM BROMIDE
CAS:7647-15-6
RTECS #:VZ3150000
Fraction by Wt: 25-30%
Ingred Name:SODIUM THIOCYANATE
CAS:540-72-7
RTECS #:XL2275000
Fraction by Wt: 10-15%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE KNOWN. MAY CAUSE SKIN AND EYES
IRRITATION.
Effects of Overexposure:NONE NOTED BY MFR. LOW TOXICITY & LOW HAZARD TO
HEALTH.
Medical Cond Aggravated by Exposure:NOT LISTED
======================= First Aid Measures =======================
First Aid:SKIN:WASH WITH SOAP AND WATER. EYES: FLUSH WITH WATER.
INHALED: REMOVE TO FRESH AIR. REMOVE CONTAMINATED CLOTHING.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING TO PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCT.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH MATERIAL TO SEWER WITH LARGE AMOUNTS OF
WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL CONTACT. KEEP
CONTAINERS TIGHTLY CLOSED
Other Precautions:AVOID STORAGE NEAR TO STRONG ACIDS.PER MFR,NO HEALTH
HAZARD WARNING LANGUAGE IS NEEDED ON THE CONTAINER.BUT GOOD
INDUSTRIAL HYGIENE PRATICE SHOULD BE FOLLOWED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT.
Other Protective Equipment:NORMAL WORK CLOTHING COVERING ARMS & LEGS.
Work Hygienic Practices:NORMAL HYGIENE PRACTICE IS RECOMMENDED.
Supplemental Safety and Health
THIS IS PART-B OF THREE PART KIT. SOLUTION NUMBER OF THIS PART IS 4450.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:100C/212F
Vapor Pres:18MMHG@20C
Vapor Density:0.6
Spec Gravity:1.39
pH:6.2
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR COLORLESS SOLUTION;ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Stability Condition to Avoid:NO INFORMATION FOUND
Hazardous Decomposition Products:CYANIDE FUMES WILL BE EVOLVED IF
THERMALLY DECOMPOSED.
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW FEDERAL,STATE & LOCAL LAWS. THIS CHEMICAL
FORMULATION HAS A LOW BIOLOGICAL OXYGEN DEMAND, & IT IS EXPECTED TO
CAUSE LITTLE OXYGEN DEPLETION IN AQUATIC SYSTEMS. IT IS EXPECTED TO
HAVE A LOW POTE NTIAL TO AFFECT AQUATIC SYSTEMS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ARDROX 6405
CAGE:KO123
CAGE:KO123
CAGE:23373
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTOXYETHANOL
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 5%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
Ingred Name:GLYCOL ETHER
CAS:111-46-6
RTECS #:ID5950000
Fraction by Wt: 5%
ACGIH TLV:S, 50PPM (MFR)
Ingred Name:SODIUM XYLENESULFONATE
CAS:1330-72-7
RTECS #:ZE5100000
Fraction by Wt: 4%
Ingred Name:ETHYLENEDIAMINE-TETRAACETIC ACID (EDTA) (SARA III)
CAS:60-00-4
RTECS #:AH4025000
Fraction by Wt: 0.25%
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SODIUM SILICATE
CAS:6834-92-0
RTECS #:VV9275000
Fraction by Wt: 0.7%
===================== Hazards Identification =====================
Effects of Overexposure:DIZZINESS & DROWSINESS
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES. CALL PHYSICIAN.
INGESTION: DO NOT INDUCE VOMITING. CALL PHYSICIAN. INHALATION:
REMOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO WASTE WITH WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL DRY AREA.
Other Precautions:AVOID SPLASHES ON SKIN & EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:N/A (MFR)
Other Protective Equipment:PVC APRON & BOOTS.
Supplemental Safety and Health
TLV: 50 PPM (GLYCOL ETHER) BY SKIN ABSORPTION. OTHER INGREDS:
EPOXYLATED ALCOHOL- 6%, CAUSTIC SODA & SULFONIC ACID- 11%, SODIUM
GLUCONATE- 3.5%, WATER- 69%. CONTAINER: 55 GAL DRUM.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F; 100C
Spec Gravity:1.05
Solubility in Water:SOLUBLE
Appearance and Odor:PALE STRAW COLORED LIQUID, GLYCOL ETHER ODOR.
Percent Volatiles by Volume:77
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:MANUFACTURER RECOMMENDS FLUSHING TO WASTE.
NEUTRALIZE IF NECESSARY. DISPOSAL METHODS MUST BE IAW FEDERAL,
STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:14483 PR1448 5 MANGANESE DIOXIDE DISPERSION ACCELERATOR
Kit Part:Y
CAGE:83574
CAGE:83574
============= Composition/Information on Ingredients =============
Ingred Name:VOLATILE ORGANIC CONTENT: 0.0 G/L
RTECS #:9999999VO
Ingred Name:HYDROGENATED TERPHENYLS
CAS:61788-32-7
RTECS #:WZ6535000
Fraction by Wt: 30%
Other REC Limits:4.7 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:1,3-DIPHENYL GUANADINE
CAS:102-06-7
RTECS #:MF0875000
Fraction by Wt: <5%
Ingred Name:MANGANESE DIOXIDE, MANGANESE PEROXIDE *98-3*
CAS:1313-13-9
RTECS #:OP0350000
Fraction by Wt: 60%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:COLUMBIA CARBON, CARBON BLACK, LAMPBLACK, BLACK PEARLS
(IARC GROUP 2B) - *98-3*
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: <5%
Other REC Limits:3.5 MG/CUM (NIOSH)
OSHA PEL:3.5 MG/CUM
ACGIH TLV:3.5 MG/CUM
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE (IARC - GROUP 3) *98-3*
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: <5%
OSHA PEL:2 MG/CUM (RESP DUST)
ACGIH TLV:2 MG/CUM (RESP DUST)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MANGANESE DIOXIDE: EYES: MAY CAUSE
IRRITATION. SKIN: IRRITATION ON MOIST SKIN. INHALATION:
OVEREXPOSURE MAY PRODUCE MANGANESE POISONING. INGESTION: CAN BE
ABSORBED THROUGH DIGESTIVE SYSTEM & RESULT IN APATHY, EMOTIONAL
DISTRESS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, APATHY, INSOMNIA, WEAKNESS IN LEGS,
MUSCULAR TWITCHING, EMOTIONAL DISTRESS
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LUKE WARM WATER FOR 15 MINS. SKIN: WASH W/SOAP
& WATER. INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION
IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:>200F
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER
Fire Fighting Procedures:USE AIR SUPPLIED RESPIRATOR. USE WATER TO COOL
HEAT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:EXCESSIVE HEAT MAY CAUSE DECOMPOSITION OF
MANGANESS DIOXIDE RESULTING IN OXIDATION & POSSIBLE IGNITION OF
HYDROCARBON VEHICLE.
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP INTO CONTAINERS. CLEAN-UP RESIDUE W/A
SUITABLE SOLVENT.
======================Handling and Storage ======================
Other Precautions:AVOID INGESTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED
Ventilation:GENERAL VENTILATION
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE SMOKING
& EATING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:644F
Spec Gravity:1.97
Appearance and Odor:BLACK PASTE
Percent Volatiles by Volume:0.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:EASILY OXIDIZABLE MATERIALS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DOUBLE X RESIN BONDED ABRASIVES
Preparer's Name:ANDY LECOUFFE
CAGE:JWALT
CAGE:JWALT
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM OXIDE, BAUXITE, ALUMINA, DIALUMINUM TRIOXIDE
*97-2*
CAS:1344-28-1
RTECS #:BD1200000
Fraction by Wt: 60-80%
OSHA PEL:15 MG/CUM TOTAL DUST
ACGIH TLV:10 MG/CUM TOTAL DUST
Ingred Name:SILICON CARBIDE
CAS:409-21-2
RTECS #:VW0450000
Fraction by Wt: 1-5%
ACGIH TLV:10 MG/CUM
Ingred Name:PHENOLIC RESIN *96-2*
CAS:54579-44-1
Fraction by Wt: 5-10%
Ingred Name:FIBERGLASS, FIBROUS (FIBER) GLASS, GLASS FIBERS *97-2*
RTECS #:LK3651000
Fraction by Wt: 1-5%
Other REC Limits:3000000 FB/CUM
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:UNCONTROLLED DUST CAN EFFECT EYES,
SKIN & RESPIRATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:UNCONTROLLED DUST CAN AFFECT EYES, SKIN &
RESPIRATION.
======================= First Aid Measures =======================
First Aid:SKIN: RINSE THOROUGHLY W/SOAP & WATER. EYES: RINSE THOROUGHLY
W/PLENTY OF WATER. DON'T REMOVE EMBEDDED OBJECTS. INHALATION:
REMOVE TO FRESH AIR. TREAT SCRAPES/CUTS BY CLENSING WOUND. APPLY
STERILE DRE SSING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, CO2, CHEMICAL
======================Handling and Storage ======================
Handling and Storage Precautions:FOLLOW SAFETY STANDARDS FOR GRINDING.
============= Exposure Controls/Personal Protection =============
Ventilation:ADEQUATE
Other Protective Equipment:PROTECTIVE CLOTHING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:>1
Appearance and Odor:CHARACTERISTIC SOLID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:NEOPRENE REPAIR/VULCANIZING CEMENT-NEUTRAL (ADHESIVE PART A)
Kit Part:Y
CAGE:7X236
CAGE:0D5X4
CAGE:7X236
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA 313) (CERCLA)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 43%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM; Z-2
ACGIH TLV:S, 50 PPM; 9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HEXANE (N-HEXANE) (CERCLA)
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: 31%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM
ACGIH TLV:50 PPM; 9596
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:POLTCHLOROPRENE RUBBERS
CAS:9010-98-4
RTECS #:EI9460000
Fraction by Wt: NP
Other REC Limits:NONE RECOMMENDED
Ingred Name:TRADE SECRET COMPONENT, TSR#:1397250002-5027P
Fraction by Wt: NP
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:NAUSEA &/OR NARCOSIS.CHRONIC:MAY
CAUSE NERVE DAMAGE.
Explanation of Carcinogenicity:PER MSDS:CARCINOGENICITY:NO.
Effects of Overexposure:IRRITATION TO EYES & MUCOUS MEMBRANES.DRY &
CRACKED SKIN.LIQUID INGESTION MAY RESULT IN
VOMITING.NUMBNESS,TINGLING & WEAKNESS OF ARMS OR LEGS.
Medical Cond Aggravated by Exposure:RESP AILMENTS.TARGET ORGAN:TOLUENE
BASED ON ANIMAL DATA MAY CAUSE LIVER
ABNORMALITIES,KIDNEY/LUNG/SPLEEN DMG.IN HUMANS LIVER
ABNORMALITIES.HEXANE MAY CAUSE CNS EFFECTS.MAY DMG PERIPHERAL NERVE
TISSUE.
======================= First Aid Measures =======================
First Aid:UTILIZE SUGGESTED METHODS LISTED BELOW.EMERGENCY SITUATIONS
NOTIFY PHYSICIAN IMMED.SKIN:WASH W/SOAP/H2O.REFER TO PHYSICIAN IF
IRRIT PERSISTS.EYE:FLUSH ABUNDANTLY W/CLEAN WATER & REFER TO
PHYSICIAN.ING EST:DONT INDUCE VOMIT.REFER TO PHYSICIAN.EXCESSIVE
INHAL:REMOVE PATIENT TO FRSH AIR OR GIVE OXYGEN.USE CPR IF PATIENT
IS NOT BREAHTING.REFER TO PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:<0F,<-18C
Autoignition Temp:Autoignition Temp Text:510F
Lower Limits:1.0
Upper Limits:7.5
Extinguishing Media:CO2, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:NIOSH/MSHA-APPROV SCBA SHOULD BE WORN.USE
WATER SPRAY TO COOL FIRE-EXPO STRUCTURES & DISPERSE VAPOR CLOUD IF
FIRE IS NOT PRESENT.
Unusual Fire/Explosion Hazard:VAPOR HEAVIER THAN AIR,MAY TRAVEL
CONSIDERABLE DISTANCE OT SOURCE OF IGNITION & FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SPILL IN
SAND,EARTH,VERMICULITE,OIL-DRI,OOL-SPEED-DRI.SHOVEL ABSORBED MATL
INTO STEEL CONTAINER & COVER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEPE CNTNR TIGHTLY CLSD & STORE IN
APPROVED SOLVENT STORAGE AREA.KEEP AWAY FROM OPEN FLAM,HEAT
SPARKS,HOT SURFACES & OXIDIZING MATLS.
Other Precautions:NA
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH-APPROVED ATM SUPPLYING OR AIR
PURIFYING RESPIRATOR FOR ORGANIC VAPORS AS REQUIRED TO MAINTAIN
EXPOSURE LEVELS BELOW RECOMMENDED LIMITS.
Ventilation:LOC EXHAU:REMOVE VAP DURING PROCESSING.MECHANICAL
EXHAU:EXPLO-PROOF EQPMT.SPEC:REDUCE VAP CONC BELOW SPECIFIC LIMITS.
Other Protective Equipment:PROTECTIVE CLOTHING AS REQUIRED TO PREVENT
SKIN CONTACT.
Work Hygienic Practices:KEEP AREA CLEAN.CLEAN UP SPILLS IMMED.PRACTICE
GOOD PERSONAL HYGIENE.
Supplemental Safety and Health
BOILING PT/FLASH PT/AUTO IGN TEMP FOR HEXANE. 3-PART KIT,SAME NSN
PNIND:B,C.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:=65.C, 149.F
Vapor Pres:76
Vapor Density:3.1
Spec Gravity:0.864
pH:NP
Viscosity:NP
Evaporation Rate & Reference:NP
Solubility in Water:NP
Appearance and Odor:TAN COLOR, CHARACTERISTIC SOLVENT ODOR.
Percent Volatiles by Volume:NP
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NA
Stability Condition to Avoid:AVOID HEAT,OPEN FLAMES,SPARKS,HOT SURFACES
& OXIDIZING AGENTS.
Hazardous Decomposition Products:OXIDES OF
CARBON,ZINC,MAGNESIUM,SULFUR.HYDROGEN CHLORIDE, HYDROGEN SULFIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL CHEMICAL & SOLVENT WASTE DISPOSAL REGULATIONS.SARA TITLE
III SEC 313 CHEMICAL:TOLUENE.
| 1 | eyes_protection_mandatory |
Subsets and Splits
No saved queries yet
Save your SQL queries to embed, download, and access them later. Queries will appear here once saved.